NCS000348_Historical File_20141030

Permit coverage
Ala LT Renewal Application Form--_— NPDES Permit Number
NCDENR National Pollutant Discharge Elimination System NCS000348
Stormwater Individual Permit
Please provide your permit number in box in the upper right hand corner, complete the information in the space provided
below and return the completed renewal form along with the required supplemental information to the address indicated.
Owner Information
* Address to which permit correspondence will be mailed
Owner / Organization Name:
CPI USA North Carolina LLC
Owner Contact:
David Groves, Plant Manager
Mailing Address:
1281 Powerhouse Drive SE
Southport, NC 28461-3155 ��������
Phone Number:
[phone]
Fax Number:
[phone] OCT 3 0 2014
E-mail address:
[e-mail]
DENR-LAND QUALITY
Facility Information
STORMWATER PERMITTING
Facility Name:
CPI USA North Carolina — Southport Plant
Facility Physical Address:
1281 Powerhouse Drive SE
Southport, NC 28461-3155
Facility Contact:
David Groves, Plant Manager
Mailing Address:
P.O. Box 10836
Southport, NC 28461
Phone Number:
[phone]
Fax Number:
[phone]
E-mail address:
[e-mail]
Permit Information
Permit Contact:
Virginia Grace
Mailing Address:
1281 Powerhouse Drive SE
Southport, NC 28461-3155
Phone Number:
[phone]
Fax Number:
[phone]
E-mail address:
[e-mail]
Discharge Information
Receiving Stream:
Duke Energy Cooling Water Canal
Stream Class:
SB
Basin:
Atlantic Ocean
Sub -Basin:
NOT APPLICABLE
Number of Outfalls:
6
Facility/Activity Changes
Please describe below any changes to your facility or activities since issuance of your permit. Attached a
separate sheet if necessary.
Changes are described in the
attached sheet
CERTIFICATION
I certify that I am familiar with the information contained in the application and that to the best of my knowledge and belief
such informatio /fir , co fete and accurate.
Si / ' Date
gnature
David Groves Plant Manager
Print or type name of person signing above
Title
SW Individual Permit Coverage Renewal
Please return this completed application form Stormwater Permitting Program
and requested supplemental information to: 1612 Mail Service Center
Raleigh, North Carolina 27699-1612

SUPPLEMENTAL INFORMATION REQUIRED FOR RENEWAL OF INDIVIDUAL
NPDES STORMWATER PERMIT
Two copies of each of the following shall accompany this submittal in order for the application
to be considered complete:
(Do not submit the site Stormwater Pollution Prevention Plan)
Initials
TSW 1. A current Site Map from the Stormwater Pollution Prevention Plan. The location of
industrial activities (including storage of materials, disposal areas, process areas and
loading and unloading areas), drainage structures, drainage areas for each outfall,
building locations and impervious surfaces should be clearly noted.
TSW 2. A summary of Analytical Monitoring results during the term of the existing permit
(if your permit required analytical sampling). Do not submit individual lab reports.
The summary can consist of a table including such items as outfall number,
parameters sampled, lab results, date sampled, and storm event data.
TSW 3. A summary of the Visual Monitoring results. Do not submit individual monitoring
reports. The summary can consist of a table including such items as outfall number,
parameters surveyed, observations, and date monitoring conducted.
TSW 4. A summary of the Best Management Practices utilized at the permitted facility.
Summary should consist of a short narrative description of each BMP's in place at
the facility. If the implementation of any BMP's is planned, please include
information on these BMP's.
TSW 5. A short narrative describing any significant changes in industrial activities at the
permitted facility. Significant changes could include the addition or deletion of
work processes, changes in material handling practices, changes in material storage
practices, and/or changes in the raw materials used by the facility.
TSW 6. Certification of the development and implementation of a Stormwater Pollution
Prevention Plan for the permitted facility (Sign and return attached form).
If the final year analytical monitoring of the existing permit term has not been completed
prior to filing the renewal submittal, then the last years monitoring results should be submitted
within 30 days of receipt of the laboratory reports. (i.e. do not withhold renewal submittal
waiting on lab results)

�1+; j,1II j�i�lii it! 1 Iil1�i if �i li��l li ",i III I�li Ill lIIII �'i 11l �lli��lll III ill
STORMW'Al, ;ERIPIO IT; ION IPRE'VENTION PLAN
�
DEVELOPMEEMENTATION
I r it( lil i�t �ITiI l ii It ? l �l l l I,. uI li li �� 111 i I I� `i III i �i�. l� i�l 11 lli liil�� Mill it it � i� �In I I T �il t �Ii1 I
.,.',; I., '
North Carolina Division of Energy, Mineral, and Land Resources - Stormwater Permitting
Facility Name: CPI USA North Carolina - Southport Plant
Permit Number: NCS000348
Location Address: 1281 Powerhouse Drive SE
Southport, NC 28461-3155
County:
"I certify, under penalty of law, that the Stormwater Pollution Prevention Plan (SPPP) document and all
attachments were developed and implemented under my direction or supervision in accordance with a system
designed to assure that qualified personnel properly gather and evaluate the information required by the SPPP.
Based on my inquiry of the person or persons who manage the system, or those persons directly responsible
for gathering the information, the information gathered is, to the best of my knowledge and belief, true,
accurate and complete."
"I certify that the SPPP has been developed, signed and retained at the named facility location, and the SPPP
has been fully implemented at this facility location in accordance with the terms and conditions of the
stormwater discharge permit."
And
"I am aware that there are significant penalties for falsifying information, including the possibility of fines and
imprisonment for knowing violations."
SEND STORMWATER POLLUTIONjPREVENI
Signature
David G oves
Print or type name of person signing above
ind return this Certification. DO NOT
ON PLAN WITH THIS CERTIFICATION.
Date iz -�; k, �
Plant Manager
Title
SPPP Certification 10/13

61 t
lL
9
ro
y �
7 F• 0] G 1f� 3 @ OEd
@ Y+ @
ci
�@ � r f
Y
@ LLJ
Im —di `o ff c r V2O ti F- (Dfu
r
fu
L m
1 w x c E E V,t' 7:3 w It m
fu vfu
v
I C `•, \\\�ti 7 a [G
3 � m •., xrx t= r=
I I I � toLM
Y (,r rn *aaa} % 1 1
v
C a, a .�•` `�4`
uo
1 • v � !!! ytx �
OCT 3 0 2014
DENR-LAND QUA! iT
STORMWATER PERMI 1
Y b "b � tr. � emi •ar,i • � 4iti o
� � ''r � m a e ,� � G � ', �4xi4 •c ^ e,
,. n Warr•"a X a b ;}i.t: o cC
s
p i
ii
rij
C Hm © I d
J VI ® ' O 4wt�Tp'#YY°ry ttti
i I 'i F
(Y O y U tY �+�I CCo 0 Faj V° r° 4�iti4
� V,,rram�
v @
--------------
E In ai C3
lz
Ql O p
a C s5 )C. c 1
d O El ,d C@ z
ui Inw V itl
tu O :3
ai
7 = 2 O
m
8 � O
VG

CPI USA North Carolina, LLC - Southport Facility
ANALYTICAL MONITORING SUMMARY
DATE:
9/27/10
7/8/11
3/19/12
10/1/12
4/12/13
10/7/13
4/8/14
OUTFALL WITH FLOW:
1
1
1
1
1
1
1
PARAMETER
UNITS
Ag
mg/L
<0.010
<0.01
<0.010
<0.02
<0.010
<0.010
<0.010
As
mg/L
<0.010
<0.010
<0.010
<0.02
0.016
0.010
<0.010
Be
mg/L
<0.010
<0.01
<0.010
<0.004
<0.010
<0.010
<0.010
Cd
mg/L
<0.010
<0.01
<0.010
<0.005
<0.010
<0.010
<0.010
Cr
mg/L
<0.010
<.0.01
<0.010
<0.02
0.027
0.030
<0.010
Cu
mg/L
<0.010
<0.01
<0.010
0.025
0.133
0.079
<0.010
Hg
mg/L
<0.0002
<0.0002
<0.0002
<0.0002
<0.0002
<0.0002
<0.0002
Ni
mg/L
<0.010
<0.01
<0.010
<0.02
0.035
0.032
<0.010
Pb
mg/L
<0.010
<0.01
<0.010
<0.015
0.072
0.020
<0.010
Sb
mg/L
<0.010
<0.01
<0.010
<0.02
0.016
<0.010
<0.010
Se
mg/L
<0.010
0.036
0.013
<0.02
<0.010
<0.010
<0.010
TI
mg/L
<0.010
<0.01
<0.010
<0.02
<0.010
<0.010
<0.010
Zn
mg/L
0.071
2.12
0.564
4.00
20.0
6.30
0.079
Al
mg/L
0.430
0.775
0.282
3.90
4.32
10.6
0.175
B
mg/L
0.053
0.242
0.189
0.142
0.041
0.042
0.036
COD
mg/L
41
<20
31
79
442
280
35
TSS
mg/L
4.9
16.5
4.2
79
236
254
7.8
Sulfate
mg/L
26
132
179
60
90
38
50
Oil and Grease (0&G)
mg/L
<5
<5
<5
<5
<5
<5
<5
pH
s.u.
7.4
7.3
7.85
6.96
no data
7.74
7.79
Total Rainfall
inches
5.65
0.78
0.33
1.10
1.34
0.84
0.84

z
LL
F
o
O
Lu
U "j
w
w
m
v
aCL
U y
co
a
w
Z
w
Z
w
Z
w
z
O
N
O
�-
a
w
z
o f
z
W
O
z
O
z
O
z
O
z
o
z
-0
o
O
z
a
w
DLIJ
S
Q
Z
Ln
O
H 0
U
w
O
I_
N
O
Z
LLJ M1•
z O
0 F
co
a
N
a., >
N
++ >
�
O N
d
o N
N
o N
N
o>-
N
W W
ul
U
O
O
O
0
Q
Z
r•
wca
w
a
J
O
LU
U
Q
LL.
M1.
W
G
G
J
m
Q
n•
0
a
>
>
>
>
r
>
>
Z
>-
U.
W
U
a
V
n•
uj
Z
O
O N
0
Q
Q=
LL
a O
W
>
r
r
>
>
>
z
r
O
'AV1
U
H
Q
NLf)
Q
Z
N
n•
W
O
-�
zo
a
w
ON
U
O
-�LLQ
Q
D
W
V)
m
a
U
v
U
a
M1•
J
OO
a
>
>
r
>
>
>
r
O
U
a
0
h•
W
07
O
a
Lu
>-
>-
>-
>-
>-
>-
Z
>
U
a
W
O
r-4
O
O
N
N
Q
\
Cr)
N00
m
\
rn
m
O
-
O
d'
J
'J =
m
F
OO
r
� u.
0

BMP Summary
'fable A, shown below, provides a list of the BMPs used at the Southport plant.
Potentially exposed materials at the Southport plant include coal, wood chips, fire derived fuel (TDF),
petroleum products stored in existing ASTs, water and wastewater treatment chemicals, limestone,
and ash.
Coal for the boiler plant is stored outside in the coal pile and coal pile runoff is treated in the low
volume wastewater system prior to discharge (i.e., it is not drained to the stormwater system). Coal is
brought in by rail at the north end of the plant and unloaded through the coal chute and transported via
conveyor belt to the coal pile. The risk of coal dust entering the storm water via fugitive dust exists
and to minimize that risk, coal unloading BMPs are used and, because the drainage adjacent to the rail
bed is through vegetative buffers, the quantity of coal reaching the receiving water is minimal. Water
is sprayed onto the coal as it is unloaded from the rail cars in one of the coal unloading BMPs. Also,
coal dust from the edges of the chute where coal is deposited is swept up daily after unloading
operations. These BMPs minimize fugitive dust transport.
The risk of the petroleum products entering the storm system is low due to the use of secondary
containment that conforms to 40 CFR 112.8(c)(2) and non-structural controls (e.g., routine
inspections) to prevent spills. Used oil is stored in a 300-gallon aboveground storage tank (AST)
located at inside the Boiler Building's Oil Storage Room, with full volume secondary containment.
Diesel is stored in a 300-gallon AST outside the Pump House, in a 1,000-gallon AST located within
the Rail Car Unloading Area, and in a 300-gallon AST near Truck Dumper 2, and each tank is
equipped with full volume secondary containment. Gasoline is stored in a 30-gallon dispenser located
in the Gasoline and Drum Storage Area which is also equipped with full volume secondary
containment. Small tanks of turbine tube oil and hydraulic oil are located on the site, as well as
transformers containing oil. Any spillage from these tanks and transformers would normally be
contained.
Chemical storage and usage is limited to the Wastewater Basin (drums and totes containing chemicals
are stored outside, equipped with secondary containment), the Demineralizer Building area, the R.O.
Building area, and the Cooling Tower Chemical Storage Area. The several chemical storage units in
the Demineralizer Building are all equipped with secondary containment and, any spills are routed to
the Neutralization Tank and then the Wastewater Basin for treatment. Spill cleanup materiels are
located inside the Warehouse and the R.O. Building. There is a dedicated Unloading Bay at the
Demineralizer Building. All chemicals used m the R.O. Building are stored in secondary
containment. A temporary tank designed to store bleach for treating well water is located within
containment just outside the R.O. Building. Chemicals stored in the Cooling Tower Chemical Storage
Area are equipped with full volume secondary containment.
The risk of ash or ash residue entering the storm system is low due to the use of curbs and good
housekeeping practices including routine street sweeping/vacuum cleaning. The risk of the petroleum
products entering the storm system is low due to the use of secondary containment that conforms to 40
CFR 112.8(c)(2) and non-structural controls (e.g., routine inspections) to prevent spills.

The risk of limestone entering the storm system is low due to the use of structural and non-structural
controls (i.e. the limestone silo and its blowers and piping are sealed, and limestone is removed from
equipment prior to maintenance). Limestone is pneumatically conveyed in closed lines. Any spills of
limestone will be promptly cleaned up.
Wood chips and TDF may spill from trucks on paved or gravel roads, the truck dumpers,
conveyors, and radial stacker. The risk of these materials contaminating stormwater is low
because stormwater from the access road flows through a sand filter to remove TSS from the
water before it is discharged off -site. State Stormwater Management Permit No. SWS 090511
includes operating and maintenance procedures for the sand filter. That permit was issued on
7-19-2013. In addition, any stormwater from bermed TDF and wood storage areas is diverted to
the waste treatment basins. Trucks are covered, tarped, or enclosed when not being loaded or
unloaded, and paved roads are swept periodically. Spilled materials are promptly cleaned up.

Table A. inventory of Mate r i a 1 s Exposed to Precipitation
Male►lals Management
Practice and Control
Stormwater
Location
Exposed Material (Amount)
Measures (BMPs)
Treatment
Al and DA7 - Ash Silos
Fly ash (indeterminate)
Good housekeeping BMPs, wet
None
and ash
slurry loading systems
loading stations
Al and DA7 - Limestone
Limestone
Sealed storage, Blowers & Piping,
None
Storage & Blowers
remove limestone from equipment
prior to maintenance
AI and DA7 -
Coal, Wood, TDF
Good housekeeping BMPs
None
Conveyors and Conveyor
(de minimis)
Tower
Al and DA7 —Paved
Wood; TDF; trash
Trucks covered, tarped, or
None
Dads
(indeterminate)
enclosed when not being loaded or
unloaded; roads swept
A2 - Transformer
Transformer oil (2 at 9,750-gal
Gravity discharge to Oil Trap Pit;
None
Yards
and 2 at 1,090-gal capacity)
oil is removed; accumulated
stormwater is pumped to
Wastewater Basin
A2 - Coal Storage
Coal (>1,000 tons)
Discharge to Wastewater Basin
None
A2 — Storage and
Wood chips (indeterminate)
Discharge to Wastewater Basin
None
conveying of wood
A2 — TDF Fuel Storage
Tire Chips ( 500+ tons)
Discharge to Wastewater Basin
None
Pad
A3 - Cooling Towers
None
None
Runoff from this area of
the cooling towers is
treated in sand filter
A3 - Cooling Tower
Proprietary chemicals (1,000-
Containment
Sand filter
Chemical Storage Areas
gal)
DA3 — Paved and gravel
Wood chips; TDF;
Hydraulic Oil Tank - Partial roof
Sand filter, Hyd. Oil
Dads, Truck Dumper 1,
Hydraulic Oil Tank (700-gal
and conforming secondary
Tank containment is
wood unloading conveyors
capacity)
containment; paved roads swept
drained to Oil Trap Pit
A3 - Truck Dumper 2
Wood chips; TDF;
Hydraulic Oil Tank and Diesel
None
Iydraulic Oil Tank (320-gal
fuel tank - Conforming secondary
capacity); Diesel fuel tank
containment
(300-gallon capacity)
A3 - Rail Car Unloading
Coal (indeterminate); Diesel
Coal unloading - covered with
None
Area
fuel tank (1,000-gallon
roof Fuel tank and hydraulic fluid
capacity); hydraulic fluid
reservoir - equipped with
reservoir (30 gallon capacity)
conforming secondary
containment
DA3 — near Coal
Coal (de minimis)
Good housekeeping BMPs for
None
Conveyor and Railroad Spur
area beneath conveyor and around
railroad spur

Table A. Inventory of Materials Exposed to Precipitation
Materials Management
Practice and Control
Stormwater
Location
Exposed Material (Amount)
Measures (BMPs)
Treatment
A3 — Switch Yard
Sulfur hexafluoride— gas
None
Sand filter
A3 - Oil Trap Pit
Typically none (12,160-gal
Oil is removed; accumulated
None
capacity)
slormwaler is pumped to
Wastewater Basin
A4 - Cooling Towers
None
None
None
A5 - Condensate Storage
None
None
None
Tank
DA5 - Demineralizer
None
None
None
Building
A5 — Neutralization
None
None
None
Tank
A5 — Pump House
Diesel fuel tank (300-gallon
Conforming secondary containment
None
capacity)
A5 — Reverse Osmosis
None
None
None
Building
A5 — Water Tanks (used
None
None
None
for raw water storage)
A5 — Paved roads and
Wood; TDF; trash
Trucks covered, tarped, or
None
trash dumpsters
(indeterminate)
enclosed when not being loaded or
unloaded; roads swept
A6
New and used equipment
None
None
storage outside
A7—Electric Fire
Transformer oil (125-gallon
Conforming secondary
None
Pump Transformer
capacity)
containment
A7 - Unloading Bay (at
None
Containment; discharge via
None
Demineralizer Building)
Den -in. Building sump to
Wastewater Basin
A7—Drum Storage
Miscellaneous drums
Containment; discharge via Demin.
None
Area
(indeterminate)
Building sump to Wastewater Basin
aydown Yard Areas
Extra material — mostly metal
None
None
piping and wood

Significant Changes in Industrial Activities
On'7-19-2013, NCDENR issued Slate Stormwater Management Permit No. SWS 090511, which
authorized the construction of a permanent sand filter. The sand filter includes operation and
maintenance conditions which are incorporated into that permit, and the filter controls the TSS
discharged in stormwater from some pervious and impervious areas within Drainage Area 3, that
are associated with equipment that was installed to reduce emissions fi•oin the boilers at [lie site.
Stormwater that has been treated by the new sand filter is discharged through
Stormwater Outfall No. 3 (003).
A new stormwater outfall, Stormwater Outfall No. 6 (006) serving Drainage Area 7, was created
during a facility improvement project. This outfall is an internal outfall which discharges
stormwater into the ditch which drains through existing Stormwater Outfall No. 5 (005).

NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins Dee Freeman
Governor Director Secretary
December 28, 2009
Individual NPDES Stormwater Permit Renewal Transmittal Cover Page
To: Wilmington Regional Office
Subject: NPDES Stormwater Permit No. NCS000348
Epcor USA North Carolina LLC
Southport, NC (Brunswick County)
Attachment Description
—
Z
Staff Report
Z
Draft Permit
Z
Renewal Application
PUMC151Vn"
BY:
JAN 0 5 2009
Please provide comments on the facility, draft permit, and staff report and sign/return
if acceptable.
Return to Brian Lowther at the Central Office by January 28, 2010.
Division of Water Quality
Stormwater Permitting Unit
1617 Mail Service Center d
Raleigh, NC 27699-1617
3
Welldl Idb arid 910111 Mdler 81 dl Id I One
1617 Mail Service Center, Raleigh, North Carolina 27699-1617
Location: 512 N. Salisbury St. Raleigh, North Carolina 27604 NofthCarofina
Phone: [phone] \ FAX: [phone] \ Customer Service: 1-877-623-6748
Internet: www,ncwaterquality.org Naturally
An Equal Opportunity 1 Affirmative Action Employer

T_
NCS000348
0� 0�W � ',,-. i
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
STAFF REVIEW AND EVALUATION
NPDES Stormwater Permit
Facility Name: EPCOR USA North Carolina LLC.
NPDES Permit Number: NC5000348
Facility Location: 1281 Powerhouse Drive Southport, NC (Brunswick County)
Type of Activity: Power Plant
SIC Code: 4911
Receiving Streams:
See Figure 1
River Basin:
Cape Fear River Basin, Sub -basin 03-06-17
Stream Classification:
SC; Sw
Proposed Permit Requirements:
See attached draft permit.
Monitoring Data:
See Table 1
Response Requested by (Date):
Central Office Staff Contact:
Return to: Brian Lowther, [phone]
Special Issues:
Issue
Rating Scale: 1(easy) to 10(hard)
Compliance history
5
Benchmark exceedance
2
Location (TMDL, ME
species, etc)
5
Other Challenges:
o Consistency with
PP Permits
9
Difficulty Rating:
21/40
Coleen 11, Sullins Director
Division of Water Quality
Special Issues Explanation:
o During this permit renewal DWQ has significantly increased efforts to more closely monitor the
power plant industry to evaluate potential impacts to stormwater (see file).
Description of Onsite Activities:
o Potentially exposed materials at the plant include coal, petroleum products stored in existing ASTs,
water treatment chemicals and ash. Coal for the boiler plant is stored outside in the coal pile and coal pile
runoff is treated in the low volume wastewater system prior to discharge.
Documents Reviewed:
o NPDES Stormwater Permit Application Materials
o National Heritage Program (NHP) Threatened and Endangered Species Database
0 SPU File
Page 1 of 10

NCS000348
o Central Files
o EPA Sector -Specific Permit, 2008, "Sector 0 — Steam Electric Generating Facilities"
0 303(d) List, 2008 draft, 2006 final
* 2006 Roanoko i asinwido Plan
History:
• April 12, 2002: Date permit first issued. Analytical monitoring includes TSS and COD. Monitoring was
done annually for the first 3 years and quarterly for the 4th year.
• September 5, 2006: Renewal permit reminder letter sent to permittee.
• October 25, 2006: Date permittee submitted renewal application
• April 7, 2008: Email from James Moore with future site changes.
• April J, 2008: Email response by Ken Pickle of the site modifications.
S
Page 2of10

NCS000348
NCSi 00348
W Seale 1:24,000
Figure 1: Map of Facility
EPCOR USA North Carolina LLC.
Southport Facility
Latitude: 330 56' V' N
Longitude: 780 0' 43" W
County: Brunswick
Reca \iing Steam: Price Creek
Stream Class: SC; Sw
Sub -basin; 03-06-17 (Cape Fear River Basin)
Facility Location
Page 3 of 10

NCS000348
Central Office Review Summary:
Owner's Other Permits:
o NCO065099 Prim Enrg of NC LLC Southport- Outfall 001 includes flow, oil & grease and TSS. Outfall
002 includes chlorine, chromium, flow, and zinc. Outfall 003 includes an annual pollutant scan. Outfall
004 includes conductivity, DO, flow, nitrogen, pH, iSS and temperature.
2. General Observations: The site has six different outfalls.
3. Impairment: Price Creek is not on the 303(d). The Basinwide Plan for Cape Fear 2005 did not mention Price
Creek.
4. Threatened and Endangered: There are many federally and state protected species within 2 miles of the
facility based on Natural Heritage Virtual Workroom I. isted are federally protected aquatic species.
o Acipenser brevirostrum (Sortnose Sturgeon) Federal E (Brackish water of large rivers and estuaries;
spawns in freshwater areas )
o Chelonia mydas (Green Seaturtle) Federal T (Nests on beaches; forages in ocean and sounds)
o Trichechus manatus (West Indian Manatee) Federal E (Warm waters of estuaries and river mouths)
5. Location: SC; Sw
6. Industrial Changes Since Previous Permit: In 2006, the facility added unadulterated wood as an alternative
fuel.
The wood is stored in a dedicated storage bin which directs rain runoff to the waste treatment basin via a vee
ditch. Transfer of the wood chips to the fuel blending area occurs within the coal yard storage area which is
drained to the plant WWTP preventing any stormwater contamination from the transfer process.
Email correspondence from James Moore ([e-mail]) on 04/07/08 indicates future changes for
the Southport and Roxboro facilities. They asked for a response on what do based on their stormwater and
waste water permits.
The changes are to be completed in early 2009. Both plants are power generation facilities that burn coal,
tire -derived fuel (TDF) and unadulterated wood to produce steam and electrical power. The electricity
generated is sold to the Grid, the steam at the Southport facility is also sold to a host.
Summary of future changes:
o Installation of a SNCR (selective non --catalytic reduction) ammonia injection for NOx Reduction.
The SNCR system will include 1 or 2 NH3 storage tanks to supply NH3 to the SNCR in the boiler off -gas
ducts. The injected NH3 will be consumed in the process. Design will provide isolation from the
wastewater systems and stormwater contact.
o Installation of Fuel Processing Equipment —grinders and additional conveyors.
The grinder will handle off -spec wood. The additional conveyors will transport additional alternative fuels
(tire derived fuel and wood). Design will be to contain fuel fines in the fuel yard. Design will contain yard
run-off and direct it through the wastewater treatment system.
Summary of Impact Assessment on the future changes:
The SNCR ammonia system will be designed to isolate the NH3 from any release that could be exposed to
rainwater resulting in contaminated run-off.
The S02 adsorbent system will be designed as a closed system to prevent any release that could be exposed to
rainwater resulting in contaminated run-off.
Page 4 of 10

NCS000348
All fuel storage areas (fuel yard) will have perimeter drainage ditches to transport run-off to the wastewater
system for treatment (solids settling and removal) prior to discharge via the NPDES permitted outfalls.
I he fuel processing equipment will be designed and operated within the fuel yard to control fugitive solids to
prevenL enLi'dinifienL In rainwater resulting Ili UanspurL of luel solids ufl-site:.
DENR's Response by Ken Pickle on April 9, 2008.
Each site is already has a Stormwater Pollution Prevention Plan. They need to update is with changes to
the site.
While the expired permit is in review, abide by the provisions of the old permit.
As the new site activities and materials add ammonia, sodium carbonate, and a grinder, we cannot offer a
comment on how these may affect the renewal of your permit. The reviewer will address changes to the
renewal permit.
Kens Pickle's notes: New materials on site appear to be: ammonia for NOx absorbtion (possibly in the form of
aqueous ammonia, a 29% supersaturated pressurized liquid; or in the form of just the gas NH3 in pressurized
tanks) and could result in a HNO3 by product or conversion of the gaseous NOx into a deposited solid that
might be transported to the innocuous material, although whether there is a resulting H2SO4 product from the
reaction is beyond my knowledge. Addition of a grinder makes me wonder if there will be piles of wood chips
or sawdust that might argue for TSS or COD monitoring to detect wood waste leachate.
7. Analytical Monitoring Notes:
o There were 7 samples submitted from 12/5/02 to 4/17/06 for TSS and COD. None of values is over the
current benchmarks.
o See Table 1 below.
o The EPA Sector -Specific Permit, 2008, "Sector 0 — Steam Electric Generating Facilities" recommends
monitoring for Fe, TSS and pH.
Benchmarks were adjusted because of the receiving stream is classified as a SC Stream (salt water).
Aluminum There is no saltwater data available on which to calculate a benchmark
Antimony There is no saltwater data available on which to calculate a benchmark
Arsenic
69 ug/L (national criteria)
Beryllium
There is no saltwater data available on which to calculate a benchmark
Boron
There is no saltwater data available on which to calculate a benchmark
Cadmium
40 ug/L (national criteria)
Chromium
1100 ug/L (national criteria for chromium VI)
Copper
5.8 ug/L (national criteria)
Lead
220 ug/L (national criteria)
Mercury
NA
Nickel
75 ug/L (national criteria)
Selenium
290 ug/L (national criteria)
Silver
2.2 ug/L (national criteria)
Thallium
5000 ug/L (limited data) (calculated 1/2 FAV)
Zinc
95 ug/L (national criteria)
Sulfate
There is no saltwater data available on which to calculate a benchmark
pH
6.8 - 8.5 (NC water quality standard)
From Nikki Remington by email, 11/20/2009.
Page 5 of 10

NCS000348
8. Qualitative Monitoring Notes:
o The visual monitoring was done 8 times from 5/20/02 to 10/4/05 on outfall 001. The monitoring
shows no signs of pollution but Is all the same. It only asks If each parameter Is acceptable and every
answer Is yeas.
Page 6of10

� J
E
LO
O
Orl-
CO
r
u
V CD
V
V
r
N
�t
C N
d s
m
� J
iC ^-
cn
fn
E
r
N
N
c-
M
C O
O �
m
C ..
r-
�-
LO
�-
ch
lyi
N
In
In
LO
m
7 C
N
M
N
.-
coN
�
C
p
+f6+ r
=-
r.
�
�r
N
rn
LO
ao
0
•-
th
O
O
0
as
a
LO
00
M
cc-
LO
ry
O
0
O
�- o C7
0
0
0
0
0
0
0
F—
O
c �
v
LO
ur)
(0
eo
a�
0
0
0
0
0
0
0
Q, ar
a
e\v
env
c`v
env
env
E m
N
O
4
Ln
LO
't
r`
t°
Lo
0')
v
0
0
0
0
0
0
0
N M
M d'
d' to
LO to
to 0
O (o
Co
O O
O O
O O
O O
0 0
0 0
0 co
H
r O
r O
r Q
—
r�
r [�
N �
10
� O
M
0 c`
0 m
o M
0 m
�Q
O O
g5 4-
o 4
t 'mod'
-�
� O--
N Q
0 0
0 0
0 0
0 0
O_
c- 0
0 'It
I_/

NCS000348
Revised Permit Recommendations: Analytical Monitoring:
1. Mairitairrirrg parameters...
a. TSS — to track solids concentration. Sandy soils and equipment/truck traffic potential source;
b. COD — submitted analytical results show moderate oxygen demand in stormwater.
2. Adding parameters... the following parameters were added as part of a comprehensive effort to investigate
stormwater pollution associated with coal-fired power plant facilities:
a. 13 priority pollutant metals (Ag, As, Be, Cd, Cr, Cu, Hg, Ni, Pb, Sb, Se, TI, Zn) plus Al and B — basis:
known association with coal and coal combustion. Draft RTI Study ('Human and Ecological Risk
Assessment of Coal Combustion Wastes', RTI, August 2007) and discussions with Robert Schreusdale
of RTI suggest these metals may signal contamination problems. I -lave also discussed contaminants
with Dr. Avner Vengosh from Duke University, who researched ash pond spills in TN last year. In
addition, RRO/DWQ has sampled discharges from cogeneration plants in the FRO area and flagged
several of these metals of concern. Finally, DWQ has little data with which to characterize stormwater
discharges from this industry but knows there is concern;
b. Sulfate —conventional pollutant associated coal;
c. 0&G — conventional pollutant associated with onsite petroleum storage and truck traffic.
3. pH added — standard addition to permit.
4. All analytical monitoring set to semi-annually. Cover letter to permittee will include language to allow the
permittee to contact DWQ and request modifications of the required monitoring parameters and/or frequency
if justified by sufficient data collection.
5. Benchmarks for analytical monitoring and Tiered monitoring system added to this draft permit.
6. Analytical and qualitative monitoring required during representative storm events. Qualitative monitoring
required regardless of representative outfall status.
7. Flow reporting replaced by total rainfall parameter.
8. Vehicle maintenance monitoring revised to semi-annually.
Other Proposed Changes to the Previous Permit:
1. See draft permit for full details.
Discussions with permittee: Gary Hickey, 910-457-5056
Jim Moore answered the questions by email:
1. Have there been any changes since filing the application?
Operational Change:
- Adjusted fuel ratios — more unadulterated wood, more tire -derived fuel (TDF), less coal
Note same fuels as prior operation —just different feed ratios
Physical Changes Affecting Stormwater:
- 2006 — addition of Reverse Osmosis (RO) System — RO reject water directed to Wastewater Basins ( RO
attachment)
- 2009 — Addition Fuel Pad for storage — stormwater directed to Wastewater Basins — planned completion
by 1212009
Page 8 of 10

NCS000348
- 2009 — New internal plant roadway — stormwater directed to Sand Filter BMP to existing Outfall #001—
planned completion by 1212009
- Note - Outfall #3 does not connect with Outfall #1 until the NPOES outfall, therefore stormwater from the
Project sand filter BMP will not be tested under the current testing procedure. This change will need to be
added to the new Stormwater Permit
- 2009 New laydown yard and contractor area — stormwater directed to Wet Detention Basin BMP to
Outfall #XXX — planned completion by XX/XXXX
- 2009 — New Buildings - small footprint, i.e., less than 2000 ft.2
2. Why are all the qualitative monitoring results the same?
I have attached the 2006 Application submitted in October of 2006. The qualitative results reflect "Y"
indicating acceptable conditions at all sampled outfalls.
3. The site map shows six different sw outfalls. Why were all of these not sampled"?
The Southport site has five (5) different drainage areas — with three SW Outfalls #1, #3, and #4
Drainage Area #1 — Power Plant bldg & surrounding area — drains to the Wastewater Treatment Plant (WWTP)
and to SW Outfall #1
Drainage Area #2 — Coal Storage Area — drains to the WWTP — no SW outfall
Drainage Area #3 — Southeast perimeter — most of area sheet flows to the perimeter ditch — NE end discharges
to Outfall #3
Drainage Area #4 — Cooling Tower Area — drains to Outfall #4
Drainage Area #5 — North and East side perimeter area — No SW outfall
No Sampling of Outfalls Nos. 3 and 4 - Based on site Topography ( mostly sheet flow from these areas to
perimenter ditches), flow from Outfalls Nos. 3 and 4 was null and hence was not sampled. See 2008 Outfall
Spreadsheet
4. Do you have vehicle maintenance onsite? No
5. How many acres is the site?
The Southport site is approximately 29.2 ACRES
Note — Southport is planning the annexation of approx. 20 acres of Progress Energy to construct a roadway to
the north side of the plant. This parcel will have a separate E&SC Plan and SW permit application submitted
separately.
Additional Information:
RO Addition information attached
2006 Southport SW Renewal Application
Note: a Coastal Stormwater Permit will be submitted shortly addressing the Southport Site modifications
Note — Refer to the NC Project Erosion & Sedimentation Control Plan which details Project changes ( submitted
to NCDENR )
Talked with Linda Willis about the site 04/02/09
Site changed names to Epcor and should have sent in a name change form.
-Stores wood chips and will burn wood chips and rubber
-Linda recommends monitoring about all six outfalls. They can apply for representative outfall status after data
has been collected. Maybe include ammonia if woodchip area is covered but it should go to their wastewater
treatment settling basins.
Page 9 of 10

NCS000348
Recommendations: Based on the documents reviewed, the application information submitted on October 25,
2006 sufficient to issue an Individual Stormwater Permit.
Prepared by (Signature) ..-� L. L.--i.��.�' Date 1 Z--, qv 9
Stormwater Permitting Unit Supervisor
for Bradley Bennett
Date
Concurrence by Regional Office Date
RO Water Quality Supervisor
Date
Regional Office Staff Comments (attach additional pages as necessary)
W? ,a.,f, labfn
Page 10 of 10

NCS000348
Recommendations: Based on the documents reviewed, the application information submitted on October 25,
2006 sufficient to issue an Individual Stormwater Permit.
Prepared by (Signature) Date 2 "1'0 of
G
Stormwater Permitting Unit Supervisor Date l z ?i _ o
for Bradley Ben ett
Concurrence by Regional Office, Date
Date
RO Water Quality Supervisor �i l� ,� , t;zk'.._A_: `. ; I __ Date U ::�' , L, l , i C
Regional Office Staff Comments (attach additional pages as necessary)
cyu�
,�e.�t��Gv�y�u�^�zw�-'�
4-0
IZ
f"
Page 10 of 10

NCS000348
STATE OF NORTII CAROLINA
DEPARI'MENT011 ENVIRONMENTAND NATURAL RESOURCES
DIVISION OF WATER QUALITY
PERMIT
TO DISCHARGE STORMWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provisions of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended,
Cogentrix Energy, Inc.
is hereby authorized to discharge stormwater from a facility located at
Cognetrix of North Carolina
Cogentrix Drive, SE
Southport
Brunswick County
to receiving waters designated as Price Creek, a class SC Sw stream, in the Cape Fear River
Basin
in accordance with the discharge limitations, monitoring requirements, and other conditions set
forth in Parts I, II, III, IV, V and VI hereof.
This permit shall become effective May 1, 2002.
This permit and the authorization to discharge shall expire at midnight on April 30, 2007
Signed this day April 12, 2002.
11W A M 0. '`L�
for Gregory J.Thorpe, Ph.D., Acting Director
Division of Water Quality
By the Authority of the Environmental Management Commission

Permit No. NCS000348
TABLE OF CONTENTS
PART I INTRODUCTION.
Section A: Individual Permit Coverage
Section B: Permitted Activities
Section C: Location Map
PART II MONITORING, CONTROLS, AND LIMITATIONS FOR PERMITTED
DISCHARGES
Section A: Stormwater Pollution Prevention Plan
Section B. Analytical Monitoring Requirements
Section C: Qualitative Monitoring Requirements
Section D: On -Site Vehicle Maintenance Monitoring Requirements
PART III STANDARD CONDITIONS
Section A: Compliance
and Liability
1.
Compliance Schedule
2.
Duty to Comply
3.
Duty Lu Mitigate
4.
Civil and Criminal Liability
5.
Oil and Hazardous Substance Liability
6.
Property Rights
7.
Severability
8.
Duty to Provide Information
9.
Penalties for Tampering
10.
Penalties for Falsification of Reports
Section B: General Conditions
1.
Individual Permit Expiration
2.
Transfers
0

NCS000348
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
PF.R MTT
TO DISCHARGE STORMWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provisions of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended,
EPCOR USA North Carolina LLC
is hereby authorized to discharge stormwater from a facility located at
Southport Facility
1281 Powerhouse Drive SE
Southport, NC
Brunswick County
to receiving waters designated as Price Creek, a class SC; Sw stream in the Cape Fear River
Basin, in accordance with the discharge limitations, monitoring requirements, and other
conditions set forth in Parts I, II, III, IV, V and VI hereof.
Note: Draft Permit Dates are Approximate
This permit shall become effective March 1, 2010.
This permit and the authorization to discharge shall expire at midnight on February 28, 2015.
Signed this day February 19, 2009.
for Coleen H. Sullins, Director
Division of Water Quality
By the Authority of the Environmental Management Commission

Permit No. NCS000348
TABLE OF CONTENTS
PART I INTRODUCTION
Section A: Individual Permit Coverage
Section B: Permitted Activities
Section C: Location Map
PART II MONITORING, CONTROLS, AND LIMITATIONS FOR PERMITTED
DISCHARGES
Section A: Stormwater Pollution Prevention Plan
Section B: Analytical Monitoring Requirements
Section C: Qualitative Monitoring Requirements
Section D: On -Site Vehicle Maintenance Monitoring Requirements
PART III STANDARD CONDITIONS FOR NPDES STORMWATER INDIVIDUAL
PERMITS
Section A: Compliance and Liability
1.
Compliance Schedule
2.
Duty to Complv
3.
Duty to Mitigate
4.
Civil and Criminal Liability
5.
Oil and Hazardous Substance Liability
6.
Property Rights
7.
Severability
8.
Duty to Provide Information
9.
Penalties for Tampering
10.
Penalties for Falsification of Reports
Section B: General Conditions
1. Individual Permit Expiration
2. Transfers
i

Permit No. NCS000348
3. Signatory Requirements
4, Individual Permit Modification, Revocation and Reissuance, or
Termination
5. Permit Actions
Section C: Operation and Maintenance of Pollution Controls
1.
Proper Operation and Maintenance
2.
Need to Halt or Reduce Not a Defense
3.
Bypassing of Storinwater Control Facilities
Section D: Monitoring
and Records
1.
Representative Sampling
2.
Recording Results
3.
Flow Measurements
4.
Test Procedures
5.
Representative Outfall
6.
Records Retention
7.
Inspection and Entry`
Section E: Reporting
Requirements
l .
Discharge Monitoring Reports
2.
Submitting Reports
3.
Availability of Reports
4.
Non-Stonnwater Discharges
5.
Planned Changes
6.
Anticipated Noncompliance
7.
Bypass
8,
Twenty-four Hour Reporting
9.
Other Noncompliance
10.
Other Information
PART IV LIMITATIONS REOPENER
PART V ADMINISTERING AND COMPLIANCE MONITORING FEE
REQUIREMENTS
PART VI DEFINITIONS
11

Permit No. NCS000348
PART I INTRODUCTION
SECTION A: INDIVIDUAL PERMIT COVERAGE
During the period beginning on the effective date of the permit and lasting until expiration, the
permittee is authorized to discharge stormwater associated with industrial activity. Such
discharges shall be controlled, limited and monitored as specified in this permit.
If industrial materials and activities are not exposed to precipitation or runoff as described in 40
CFR § 122.26(g), the facility may qualify for a No Exposure Exclusion from NPDES stormwater
discharge permit requirements. Any owner or operator wishing to obtain a No Exposure
Certification must submit a No Exposure Certification NOI form to the Division; must receive
approval by the Division; must maintain no exposure conditions unless authorized to discharge
under a valid NPDES stormwater permit; and must reapply for the No Exposure Exclusion once
every five (5) years.
SECTION B: PERMITTED .ACTIVITIES
Until this permit expires or is modified or revoked, the permittee is authorized to discharge
stormwater to the surface waters of North Carolina or separate storm sewer system that has been
adequately treated and managed in accordance with the terms and conditions of this individual
permit. All stormwater discharges shall be in accordance with the conditions of this permit.
Any other point source discharge to surface waters of the state is prohibited unless it is an
allowable non-stormwater discharge or is covered by another permit, authorization, or approval.
The stormwater discharges allowed by this individual permit shall not cause or contribute to
violations of Water Quality Standards.
This permit does not relieve the permittee from responsibility for compliance with any other
applicable federal, state, or local law, rule, standard, ordinance, order, judgment, or decree.
Part I Page 1 of 2

SECTION C: LOCATION MAP
Permit No. NCS000348
t 7.
a� i
a�rlva[e �f i • t �' ,� C m `���, ; ) �+r� f-' 6 ..�'d tom, �d Y'rw�"'*',�.r.�'"
1 ,s jJ ' +• S � 4 � v�' ;i,\ttii �i �il� :.;�+ t i� ate'; ,.;�.' "•..a.. .. �C`r++, '}h++^an-,�.i.(1'
� �
��I.A
^.
4 f1
'.r-'ti`�{ �� •• � _��, )
"i � � t {J,�.�,'ff ��'� Y J,TyA. � �\ ` f 9^l'7 5..r. � .fit l��! IG+..�+s
":. ;h� •. ' r"yt � 1 I -.J�i 1� \ \� 1, 1 11 �4"^c ��• '�`• Y � }.�.
Il t
jjj.
�,G!�~`' .der+'... .-ri}._,..��.-,i�•c � `��' }� firms � .._-.,.�tt<�`,�il!'r r� FSfi r .Lk. ��� � f�" � �1.:
k
r.' P :i •. JSrn vFtt ,�h% I :� �t� l,�+�a.0 "�i �,. •k
100 v
6r ff yam`*" "'rr /
jj
.5��. �.Y,{:is � IL; �F►- r lip 1 .:t:.brtf+ .t. {._tom � ttt
' �yy '� �
�
S1C1` � - tco.,.d.• _
-jf¢p f';_. .- -.._. Y� }e'�.. .a lyr ��`-;r"^ y,
f`-y� � {�� '-� � lam/--n ......'� - ...F•y � ,�•v (^- f •� '1'r
�,; ��` N ._.. ;r as✓ �; 1 EPCOR USA Southport Fadlity .p��,.` Y �.t
i H j r 4 qT r, 3 "� t
r\)-,I
-
✓ ..'.`•:_. �h � ���7r± r •. �r ) �. �,� y ...e y � �� ' rlal rv_ r •-_. ��T� %r' i
1 t�
_ Y 2"
...� 1v�R .� Jrr �. `w.r' 3/✓r ^!�� 1<: yy� f� }S� t 7:� �� �.. �i _....
G•�Gr� �f�l
�"°...,, • �' , 1 ""'�
f �` r' i7iK'..�- F
i�f.,$.�+'A
S'
f`'� �t � .0 fit' � , 7 six 4 { Jjr-..� j� J '�� �t F ayFl!1 Pi'• .ei: �����'`
o is ..1 �;.; .�1..�,$ ✓`�.,r n�J � 1-3� y � r^�f�
WAiF.'f:.:
•
NCS000348
EPCOR USA North Carolina LLC.
IN
Southport Facility
Latitude: 331156' 40" N
- -
7 ,
r
/�1 f
Longitude; 780 0' 43" W
County: Brunswick
Receiving Stream: Price Creek
Stream Cass: SC; Sw
Map Scale 1:24,000
Sub -basin: 03-06-17 (Cape Fear River Basin)
Facility Location
Part I Page 2 of 2

Pen -nit No. NCS00348
PART Ii MONITORING, CONTROLS, AND LIMITATIONS FOR
PERMITTED DISCHARGES
SECTION A: STORMWATER POLLUTION PREVENTION PLAN
The Permittee shall develop a Stormwater Pollution Prevention Plan, herein after referred to as
the Plan. This Plan shall be considered public information in accordance with Part III, Standard
Conditions, Section E, Paragraph 3 of this individual permit. The Plan shall include, at a
minimum, the following items:
1. Site Plan. The site plan shall provide a description of the physical facility and the
potential pollutant sources which may be expected to contribute to contamination of
stormwater discharges. The site plan shall contain the following:
(a) A general location map (USGS quadrangle map or appropriately drafted
equivalent map), showing the facility's location in relation to transportation
routes and surface waters, the name of the receiving water(s) to which the
stormwater outfall(s) discharges, or if the discharge is to a municipal separate
storm sewer system, the name of the municipality and the ultimate receiving
waters, and accurate latitude and longitude of the point(s) of discharge. The
general location map (or alternatively the site map) shall identify whether each
receiving water is impaired (on the state's 303(d) list of impaired waters) or is
located in a watershed for which a TMDL has been established, and what the
parameter(s) of concern are.
North Carolina's 303(d) List can be found here:
http ://h2o.enr.state.ne.us/tmdUGeneral_303d.htm#Downlo ads
North Carolina TMDL documents can be found here:
http://h2o.enr.state.ne.us/tmdUTMDL list.htm#Final TMDLs.
(b) A narrative description of storage practices, loading and unloading activities,
outdoor process areas, dust or particulate generating or control processes, and
waste disposal practices. A narrative description of the potential pollutants which
could be expected to be present in the stormwater discharge from each outfall.
(c) A site map drawn to scale (including a distance legend) showing: the site property
boundary, the stormwater discharge outfalls, all on -site and adjacent surface
waters and wetlands, industrial activity areas (including storage of materials,
disposal areas, process areas, loading and unloading areas, and haul roads), site
topography, all drainage features and structures, drainage areas for each outfall,
direction of flow in each drainage area, industrial activities occurring in each
drainage area, buildings, existing BMPs, and impervious surfaces. The site map
must indicate the percentage of each drainage area that is impervious.
(d) A list of significant spills or leaks of pollutants that have occurred at the facility
during the three (3) previous years and any corrective actions taken to mitigate
spill impacts.
Part II Page 1 of 11

Permit No. NCS00348
(e) Certification that the stormwater outfalls have been evaluated for the presence of
non storutwatot discharges. The aottificatior► staten ont will be signed in
accordance with the requirements found in Part I1I, Standard Conditions, Section
B, Paragraph 3. The permittee shall re -certify annually that the stormwater
outfalls have been evaluated for the presence of non-stormwater discharges.
2. Stormwater Management Plan. The stormwater management plan shall contain a
narrative description of the materials management practices employed which control or
minimize the exposure of significant materials to stormwater, including structural and
11UtrstruCtlltal trreasutes. The stonnwatet inanagetnetrt Platt, at a tilittitttutn, shall
incorporate the following:
(a) Feasibility Study. A review of the technical and economic feasibility of changing
the methods of operations and/or storage practices to eliminate or reduce exposure
of materials and processes to stormwater. Wherever practical, the permittee shall
prevent exposure of all storage areas, material handling operations, and
manufacturing or fueling operations. In areas where elimination of exposure is
not practical, the stormwater management plan shall document the feasibility of
diverting the stormwater runoff away from areas of potential contamination.
(b) Secondary Containment Requirements and Records. Secondary containment is
required for: bulk storage of liquid materials; storage in any amount of Section
313 of Title III of the Superfund Amendments and Reauthorization Act (SARA)
water priority chemicals; and storage in any amount of hazardous substances, in
order to prevent leaks and spills from contaminating stormwater runoff. A table
or summary of all such tanks and stored materials and their associated secondary
containment areas shall be maintained. If the secondary containment devices are
connected directly to stormwater conveyance systems, the connection shall be
controlled by manually activated valves or other similar devices (which shall be
secured closed with a locking mechanism), and any stormwater that accumulates
in the containment area shall be at a minimum visually observed for color, foam,
outfall staining, visible sheens and dry weather flow, prior to release of the
accumulated stormwater. Accumulated stormwater shall be released if found to
be uncontaminated by the material stored within the containment area. Records
documenting the individual making the observation, the description of the
accumulated stormwater, and the date and time of the release shall be kept for a
period of five years.
(c) BMP Summary. A listing of site structural and non-structural Best Management
Practices (BMP) shall be provided. The installation and implementation of BMPs
shall be based on the assessment of the potential for sources to contribute
significant quantities of pollutants to stormwater discharges and data collected
through monitoring of stormwater discharges. The BMP Summary shall include a
written record of the specific rationale for installation and implementation of the
selected site BMPs. The BMP Summary shall be reviewed and updated annually.
Part II Page 2 of 11

Permit No. NCS00348
Spill Prevention and Response Plan. The Spill Prevention and Response Plan (SPRP)
shall incorporate an assessment of potential pollutant sources based on a materials
inventory of the facility. Facility personnel (or the team) responsible for implementing the
SPRP shall be identified in a written list incorporated into the SPRP and signed and dated
by each individual acknowledging their responsibilities for the plan. A responsible
person shall be on -site at all times during facility operations that have the potential to
contaminate stormwater runoff through spills or exposure of materials associated with the
facility operations. The SPRP must be site stormwater specific. Therefore, an oil Spill
Prevention Control and Countermeasure plan (SPCC) may be a component of the SPRP,
but may not be sufficient to completely address the stoi7nwater aspects of the SPRP. The
common elements of the SPCC with the SPRP may be incorporated by reference into the
SPRP.
4. Preventative Maintenance and Good Housekeeping Program. A preventative
maintenance and good housekeeping program shall be developed. The program shall list
all stormwater control systems, stormwater discharge outfalls, all on -site and adjacent
surface waters and wetlands, industrial activity areas (including material storage areas,
material handling areas, disposal areas, process areas,loading and unloading areas, and
haul roads), all drainage features and structures, and existing structural BMPs. The
program shall establish schedules of inspections, maintenance, and housekeeping
activities of stormwater control systems, as well as facility equipment, facility areas, and
facility systems that present a potential for stormwater exposure or stormwater pollution.
Inspection of material handling areas and regular cleaning schedules of these areas shall
be incorporated into the program.- Timely compliance with the established schedules for
inspections, maintenance, and housekeeping shall be recorded in writing and maintained
in the SPPP.
5. Employee Training. Training programs shall be developed and training provided at a
minimum on an annual basis for facility personnel with responsibilities for: spill response
and cleanup, preventative maintenance activities, and for any of the facility's operations
that have the potential to contaminate stormwater runoff. Facility personnel (or team)
responsible for implementing the training shall be identified, and their annual training
shall be documented by the signature of each employee trained.
6. Responsible Party. The Stormwater Pollution Prevention Plan shall identify a specific
position(s) responsible for the overall coordination, development, implementation, and
revision to the Plan. Responsibilities for all components of the Plan shall be documented
and position assignments provided.
7. Plan Amendment. The permittee shall amend the Plan whenever there is a change in
design, construction, operation, or maintenance which has a significant effect on the
potential for the discharge of pollutants to surface waters. All aspects of the Stormwater
Pollution Prevention Plan shall be reviewed and updated on an annual basis. The annual
update shall include an updated list of significant spills or leaks of pollutants for the
previous three years, or the notation that no spills have occurred. The annual update shall
include re -certification that the stormwater outfalls have been evaluated for the presence
of non-stormwater discharges. Each annual update shall include a re-evaluation of the
Part II Page 3 of 11

Permit No. NCS00348
effectiveness of the BMPs listed in the BMP Summary of the Storinwater Management
Plan.
The Director may notify the permittee when the Plan does not meet one or more of the
minimum requirements of the permit. Within 30 days of such notice, the permittee shall
submit a time schedule to the Director for modifying the Plan to meet minimum
requirements. The permittee shall provide certification in writing (in accordance with
Part III, Standard Conditions, Section B, Paragraph 5) to the Director that the changes
have been made.
8. Facility Inspections. Inspections of the facility and all stormwater systems shall occur as
part of the Preventative Maintenance and Good Housekeeping Program at a minimum on
a semi-annual schedule, once during the first half of the year (January to June), and once
during the second half (July to December), with at least 60 days separating inspection
dates (unless performed more frequently than semi-annually). These facility inspections
are different from, and in addition to, the stormwater discharge characteristic monitoring
required in Part II B, C and D of this permit.
9. Implementation. The permittee shall implement the Plan. Implementation of the Plan
shall include documentation of all monitoring, measurements, inspections, maintenance
activities, and training provided to employees,including the log of the sampling data and
of actions taken to implement BMPs associated with the industrial activities, including
vehicle maintenance activities. Such documentation shall be kept on -site for a period of
five years and made available to the Director or the Director's authorized representative
immediately upon request.
Part II Page 4 of I I

Permit No. NCS00348
SECTION B: ANALYTICAL MONITORING REQUIREMENTS
Analytical monitoring of stormwater discharges shall be performed as specified in 'fable 1. All
analytical monitoring shall be performed during a representative storm event. The required
monitoring will result in a minimum of ten analytical samplings being conducted over the term of
the permit at each stormwater discharge outfall (SDO).
A representative storm event is a storm event that measures greater than 0.1 inches of rainfall. The
time between this storm event and the previous storm event measuring greater than 0.1 inches must be at
least 72 hours. A single storm event may have a period of no precipitation of up to 10 hours. For
example, if it rains but stops before producing any collectable discharge, a sample may be collected if the
next rain producing a discharge begins within 10 hours.
Table 1. Analytical Monitorinlz Requirements
Discharge
Measurement
Sample
Sample
Characteristics
Units
Fre uenc` l-
Type2
Location3
40 CFR Part 423 Appendix A:
Grab
SDO
13 Priority Pollutant Metals
µg/1
semi-annual
(Ag, As, Be, Cd, Cr, Cu, Hg,
Ni, Pb, Sb, Se, Tl, Zn) 4
Al
µg/1
semi-annual
Grab
SDO
B ,%
µg/1
semi-annual
Grab
SDO
COD
mg/1
semi-annual
Grab
SDO
TSS
mg/1
semi-annual
Grab
SDO
Sulfate
mg/1
semi-annual
Grab
SDO
Oil and Grease (O&G)
mg/1
semi-annual
Grab
SDO
pH
standard
semi-annual
Grab
SDO
Total Rainfalls
inches
semi-annual
Rain Gauge
-
Footnotes.
I Measurement Frequency: Twice per year during a representative storm event, for each year until either another
permit is issued for this facility or until this permit is revoked or rescinded. If at the end of this permitting cycle
the permittee has submitted the appropriate paperwork for a renewal permit before the submittal deadline, the
permittee will be considered for a renewal application. The applicant must continue semi-annual monitoring until
the renewed permit is issued. See Table 2 for schedule of monitoring periods through the end of this permitting
cycle.
2 If the stormwater runoff is controlled by a stormwater detention pond, a grab sample of the discharge from the
pond shall be collected within the first 30 minutes of discharge.
3 Sample Location: Samples shall be collected at each stormwater discharge outfall (SDO) unless representative
outfall status has been granted.
4 Mercury shall be analyzed by EPA Low-level detection method 1631E. This method also requires a field blank
be analyzed. A benchmark does not apply; however, values above 0.012 µg/1 should be noted on annual SDO
DMR reports to the Regional Office.
Part II Page 5 of 11

Permit No. NCS00348
5 For each sampled representative storm event the total precipitation must be recorded. An on -site rain gauge or
looal rain gauge reading must be recorded.
The permittee shall complete the minimum ten analytical samplings in accordance with the
schedule specified below in Table 2. A minimum of 60 days must separate each sample date
unless monthly monitoring has been instituted under a Tier Two response.
Table 2. Monitoring Schedule
Monitoring period '
Sample Number
Start
End
Year 1 — Period 1
Year 1 — Period 2
1
2
January 1, 2010
July 1, 2010
June 30, 2010
December 31, 2010
Year 2 — Period 1
3
January 1, 2011
June 30, 2011
Year 2 — Period 2
4
July 1, 2011
December 31, 2011
Year 3 — Period 1
5
January 1`, 2012
June 30, 2012
Year 3 — Period 2
6
July 1, 2012
December 31, 2012
Year 4 — Period 1
7
January 1, 2013
June 30, 2013
Year 4 — Period 2
8
July 1, 2013
December 31, 2013
Year 5 — Period 1
9
January 1, 2014
June 30, 2013
Year 5 — Period 2
10
July 1, 2014
December 31, 2014
Footnotes:
1 Maintain semi-annual monitoring during permit renewal process. The applicant must continue semi-annual
monitoring until the renewed permit is issued.
2 If no discharge occurs during the sampling period, the permittee must submit a monitoring report indicating "No
Flow" within 30 days of the end of the six-month sampling period.
The permittee shall report the analytical results from the first sample with valid results within the
monitoring period. In addition, a separate signed Annual Summary DMR copy shall be
submitted to the local DWQ Regional Office (RO) by March 1 of each year. The pennittee
shall compare monitoring results to the benchmark values in Table 3. The benchmark values in
Table 3 are not permit limits but should be used as guidelines for the permittee's Stormwater
Pollution Prevention Plan (SPPP). Exceedences of benchmark values require the pennittee to
increase monitoring, increase management actions, increase record keeping, and/or install
stormwater Best Management Practices (BMPs) in a tiered program. See below the descriptions
of Tier One and Tier Two.
Part II Page 6 of 11

Permit No. NCS00348
Table 3. Benchmark Values for Analytical Monitoring
Discharge Characteristics
Aluminum
Units
TT g/1
Benchmark
N/A I
Antimony
mg/1
N/A i
Arsenic
111"'i
0.069
Beryllium
mg/1
N/AI
Boron
mg/1
N/A'
Cadmium
II1 °,-,
0,040
Chromium
Copper
t tt iI
0.0058
Lead
0.22
Mercury
µg/1
N/A
Nickel
0.075
Selenium
111g/1
0.290
Silver
tug/l
0.0022
Thallium
mg/1,
N/A
Zinc
;111 '1
0.095
COD
mg/1
120
TSS
mg/1
100
Sulfate
mg/1
500
O&G
mg/1
30
pH (see footnote 2)
standard
6,8 -- 8.5�
Footnotes:
1 No saltwater data available to calculate a benchmark.
2 If pH values outside this range are recorded in sampled stormwater discharges, but ambient rainfall data
indicate precipitation pH levels are within + 0.1 standard units of the measured discharge values or
lower, then the lower threshold of this benchmark range does not apply. Readings from an on site or local rain
gauge (or local precipitation data) must be documented to demonstrate background concentrations were below
the benchmark pH range.
Part II Page 7 of 11

Permit No. NCS00348
'Pier One
If: The first valid sampling results are above a benchmark value, or outside of the benchmark
for anv parameter at anv outfall;
Then: The permittee shall:
1. Conduct a stormwater management inspection of the facility within two weeks of receiving
sampling results.
2. Identify and evaluate possible causes of the benclunark value exceedence.
3. Identify potential, and select the specific: source controls, operational controls, or physical
improvements to reduce concentrations of the parameters of concern, or to bring
concentrations to within the benchmark range.
4. Implement the selected actions within two months of the inspection.
5. Record each instance of a Tier One response in the Stormwater Pollution Prevention Plan.
Include the date and value of the benchmark exceedence, the inspection date, the personnel
conducting the inspection, the selected actions, and the date the selected actions were
implemented.
Tier Two
If: During the term of this permit, the first valid sampling results from two consecutive
monitoring periods are above the benchmark values, or outside of the benchmark range, for any
specific parameter at a specific discharge outfall;
Then: The permittee shall:
1. Repeat all the required actions outlined above in Tier One.
2. Immediately institute monthly monitoring for all parameters (except mercury) at every
outfall where a sampling result exceeded the benchmark value for two consecutive samples
Monthly (analytical and qualitative) monitoring shall continue until three consecutive
sample results are below the benchmark values, or within the benchmark range, for all
parameters at that outfall.
3. If no discharge occurs during the sampling period, the permittee is required to submit a
monthly monitoring report indicating "No Flow."
4. Maintain a record of the Tier Two response in the Stormwater Pollution Prevention Plan.
Part II Page 8 of 1 I

Permit No. NCS00348
During tho term of this ponnit, if tho valid sampling results roquirod for tho permit monitoring
periods exceed the benclunark value, or are outside the benclunark range, for any specific
parameter at any specific outfall on four occasions, the permittee shall notify the DWQ
Wilmington Regional Office Supervisor in writing within 30 days of receipt of the fourth
analytical results. DWQ may, but is not limited to:
• Require that the permittee increase or decrease the monitoring frequency for the
remainder of the permit;
• Work with the permittee to develop alternative response strategies;
• Require the pennittee to install structural stonnwater controls;
• Require the permittee to implement other stormwater control measures; or
• Require that the permittee implement site modifications to qualify for the No Exposure
Exclusion.
Part II Page 9 of 11

Permit No. NCS00348
SECTION C: QUALITATIVE MONITORING REQUIREMENTS
Qualitative monitotng teduues a visual inspection of each stonnwater outfall regardless of
representative outfall status and shall be performed as specified in Table 4, during the analytical
monitoring event. Qualitative monitoring is for the purpose of evaluating the effectiveness of the
Stormwater Pollution Prevention Plan (SPPP) and assessing new sources of stormwater pollution.
In the event an atypical condition is noted at a stormwater discharge outfall, the permittee shall
document the suspected cause of the condition and any actions taken in response to the
discovery. This documentation will be maintained with the SPPP.
'fable 4. Qualitative Monitoring Requirements
Discharge Characteristics
Frequencyl
Monitoring
Location2
Color
semi-annual
SDO
Odor
semi-annual
SDO
Clarity
semi-annual
SDO
Floating Solids
semi-annual
SDO
Suspended Solids
semi-annual
SDO
Foam
semi-annual
SDO
Oil Sheen
semi-annual
SDO
Erosion or deposition at the
semi-annual
SDO
outfall
Other obvious indicators
semi-annual
SDO
of stormwater pollution
Footnotes:
1 Measurement Frequency: Twice per year during a representative storm event, for each year until either another
permit is issued for this facility or until this permit is revoked or rescinded. If at the end of this permitting cycle
the permittee has submitted the appropriate paperwork for a renewal permit befoie the submittal deadline, the
permittee will be considered for a renewal application. The applicant must continue semi-annual monitoring until
the renewed permit is issued. See Table 2 for schedule of monitoring periods through the end of this permitting
cycle.
2 Monitoring Location: Qualitative monitoring shall be performed at each stormwater discharge outfall (SDO)
regardless of representative outfall status.
SECTION D: ON -SITE VEHICLE MAINTENANCE MONITORING REQUIREMENTS
Facilities which have any vehicle maintenance activity occurring on -site which uses more than 55
gallons of new motor oil per month when averaged over the calendar year shall perform
analytical monitoring as specified below in Table S. This monitoring shall be performed at all
stormwater discharge outfalls which discharge stormwater runoff' from vehicle maintenance areas
and in accordance with the schedule presented in Table 2 (Section B). All analytical monitoring
shall be performed during a representative storm event.
Part II Page 10 of 11

Permit No. NCS00348
Table 5. Analytical Monitoring Requirements for On -Site Vehicle Maintenance
Discharge Characteristics
Units
Measurement
Fre uenc 1
Sample
Type2
Sample
Location3
pH
standard
semi-annual
Grab
SDO
Total Petroleum Hydrocarbons
EPA Method 1664 (SGT-HEM)
mg/1
semi-annual
Grab
SDO
Total Suspended Solids
mg/1
semi-annual
Grab
SDO
Total Rainfall4
inches
semi-annual
Rain gauge
Estimate
-
New Motor Oil Usage
gallons/month
semi-annual
Footnotes:
I Measurement Frequency: Twice per year during a representative storm event, for each year until either another
permit is issued for this facility or until this permit is revoked or rescinded. If at the end of this permitting cycle
the permittee has submitted the appropriate paperwork for a renewal permit before the submittal deadline, the
permittee will be considered for a renewal application. The applicant must continue semi-annual monitoring until
the renewed permit is issued. See Table 2 for schedule of monitoring periods through the end of this permitting
cycle.
2 If the stormwater runoff is controlled by a stormwater detention pond a grab sample of the discharge from the
pond shall be collected within the first 30 minutes of discharge from the pond.
3 Sample Location: Samples shall be collected at each stormwater discharge outfall (SDO) that discharges
stormwater runoff from area(s) where vehicle maintenance activities occur.
4 For each sampled representative storm event the total precipitation must be recorded. An on -site or local rain
gauge reading must be recorded.
Monitoring results shall be compared to the benchmark values in Table 6. The benchmark
values in Table 6 are not permit limits but should be used as guidelines for the permittee's
Stormwater Pollution Prevention Plan (SPPP). Exceedences of benchmark values require the
permittee to increase monitoring, increase management actions, increase record keeping, and/or
install stormwater Best Management Practices (BMPs), as provided in Part II Section B.
Table 6. Benchmark Values for Vehicle Maintenance Analytical Monitoring
Discharge Characteristics
Units
Benchmark
pH (see footnote 1)
standard
6-9t
Total Petroleum Hydrocarbons (TPH)
mg/L
15
Total Suspended Solids
mg/L
100
Footnotes:
1 If pH values outside this range are recorded in sampled stormwater discharges, but ambient rainfall data
indicate precipitation pH levels are within + 0.1 standard units of the measured values or lower, then the
lower threshold of this benchmark range does not apply. Readings from an on -site or local rain gauge (or local
precipitation data) must be documented to demonstrate background concentrations were below the normal pH
range.
Part 11 Page 11 of 11

Permit No. NCS00348
PART III STANDARD CONDITIONS FOR NPDES STORMWATER INDIVIDUAL PERMITS
SECTION A: COMPLIANCE AND LIABILITY
Compliance Schedule
The permittee shall comply with Limitations and Controls specified for stormwater discharges in
accordance with the following schedule:
Existing Facilities already operating but applying for permit coverage for the first time: The Stormwater
Pollution Prevention Plan shall be developed and implemented within 12 months of the effective date of the
initial permit and updated thereafter on an annual basis. Secondary containment, as specified in Part II,
Section A, Paragraph 2(b) of this permit, shall be accomplished within 12 months of the effective date of
the initial permit issuance.
New Facilities applying for coverage for the first time and existing` facilities previously permitted and
applying for renewal under this permit: The Stormwater Pollution Prevention Plan shall be developed and
implemented prior to the beginning of discharges from the operation of the industrial activity and be
updated thereafter on an annual basis. Secondary containment, as specified in Part II, Section A, Paragraph
2(b) of this permit shall be accomplished prior to the beginning of discharges from the operation of the
industrial activity.
2. Duty to Comely
The permittee must comply with all conditions of this individual permit. Any permit noncompliance
constitutes a violation of the Clean Water Act and is grounds for enforcement action; for permit
termination, revocation and reissuance, or modification; or denial of a permit upon renewal application.
The permittee shall comply with standards or prohibitions established under section 307(a) of the
Clean Water Act for toxic pollutants within the time provided in the regulations that establish these
standards or prohibitions, even if the permit has not yet been modified to incorporate the
requirement.
b. The Clean Water Act provides that any person who violates a permit condition is subject to a civil
penalty not to exceed $25,000 per day for each violation. Any person who negligently violates any
permit condition is subject to criminal penalties of $2,500 to 25,000 per day of violation, or
imprisonment for not more than 1 year, or both. Any person who knowingly violates permit
conditions is subject to criminal penalties of $5,000 to $50,000 per day of violation, or
imprisonment for not more than 3 years, or both. Also, any person who violates a permit condition
may be assessed an administrative penalty not to exceed $10,000 per violation with the maximum
amount not to exceed $125,000. [Ref: Section 309 of the Federal Act 33 USC 1319 and 40 CFR
122.41(a).]
C. Under state law, a daily civil penalty of not more than ten thousand dollars ($10,000) per violation
may be assessed against any person who violates or fails to act in accordance with the terms,
conditions, or requirements of a permit. [Ref: NC General Statutes 143-215.6A].
d. Any person may be assessed an administrative penalty by the Director for violating section 301,
302, 306, 307, 308, 318 or 405 of the Act, or any permit condition or limitation implementing any
of such sections in a permit issued under section 402 of the Act. Administrative penalties for Class
I violations are not to exceed $10,000 per violation, with the maximum amount of any Class I
penalty assessed not to exceed $25,000, Penalties for Class II violations are not to exceed
Part III Page 1 of 8

Permit No. NCS00348
$10,000 per day for each day during which the violation continues, with the maximum amount of
any Class iI penalty not to exceed $125,000.
Duty to Mitigate
The permittee shall take all reasonable steps to minimize or prevent any discharge in violation of this
individual permit which has a reasonable likelihood of adversely affecting human health or the environment.
Civil and Criminal Liability
Except as provided in Part III, Section C of this permit regarding bypassing of storrawater control facilities,
nothing in this individual permit shall be construed to relieve the permittee from any responsibilities,
liabilities, or penalties for noncompliance pursuant to NCGS 143-215.3, 143-215.6A, 143-215.613, 143-
215.6C or Section 309 of the Federal Act, 33 USC 1319. Furthermore, the permittee is responsible for
consequential damages, such as fish kills, even though the responsibility for effective compliance may be
temporarily suspended.
5. Oil and Hazardous Substance Liabilitv
Nothing in this individual permit shall be construed to preclude the institution of any legal action or relieve
the permittee from any responsibilities, liabilities, or penalties to which the permittee is or may be subject to
under NCGS 143-215.75 et seq, or Section 311 of the Federal Act, 33 USC 1321.
6. Property Rights
The issuance of this individual permit does not convey any property rights in either real or personal
property, or any exclusive privileges, nor does it authorize any injury to private property or any invasion of
personal rights, nor any infringement of Federal, State or local laws or regulations.
7. Severability
The provisions of this individual permit are severable, and if any provision of this individual permit, or the
application of any provision of this individual permit to any circumstances, is held invalid, the application
of such provision to other circumstances, and the remainder of this individual permit, shall not be affected
thereby.
8. Duty to Provide Information
The permittee shall furnish to the Director, within a reasonable time, any information which the Director
may request to determine whether cause exists for modifying, revoking and reissuing, or terminating the
permit issued pursuant to this individual permit or to determine compliance with this individual permit. The
permittee shall also furnish to the Director upon request, copies of records required to be kept by this
individual permit.
9. Penalties for Tampering
The Clean Water Act provides that any person who falsifies, tampers with, or knowingly renders inaccurate,
any monitoring device or method required to be maintained under this individual permit shall, upon
conviction, be punished by a fine of not more than $10,000 per violation, or by imprisonment for not more
than two years per violation, or by both. If a conviction of a person is for a violation committed after a first
conviction of such person under this paragraph, punishment is a fine of not more that $20,000 per day of
violation, or by imprisonment of not more than 4 years, or both.
Part III Page 2 of 8

Permit No. NCS00348
10. Penalties for Falsification of Reports
The Clean Water Act provides that any person who knowingly males any false statement, rcpresontation, or
certification in any record or other document submitted or required to be maintained under this individual
permit, including monitoring reports or reports of compliance or noncompliance shall, upon conviction, be
punished by a fine of not more than $10,000 per violation, or by imprisonment for not more than two years
per violation, or by both.
SECTION B: GENERAL CONDITIONS
Individual Permit F.,xpiration
The permittee is not authorized to discharge after the expiration date. In order to receive automatic
authorization to discharge beyond the expiration date, the permittee shall submit forms and fees as are
required by the agency authorized to issue permits no later than 180 days prior to the expiration date. Any
permittee that has not requested renewal at least 180 days prior to expiration, or any permittee that does not
have a permit after the expiration and has not requested renewal at least 180 days prior to expiration, will be
subjected to enforcement procedures as provided in NCGS § 143-215.6 and 33 USC 1251 et. seq.
Transfers
This permit is not transferable to any person except after notice to and approval by the Director. The
Director may require modification or revocation and reissuance of the permit to change the name and
incorporate such other requirements as may be necessary under the Clean Water Act. The Permittee is
required to notify the Division in writing in the event the permitted facility is sold or closed.
Signatory Requirements
All applications, reports, or information submitted to the Director shall be signed and certified.
a. All applications to be covered under this individual permit shall be signed as follows:
(1) In the case of a corporation: by a principal executive officer of at least the level of vice-
president, or his duly authorized representative, if such representative is responsible for
the overall operation of the facility from which the discharge described in the permit
application form originates;
(2) In the case of a partnership or limited partnership: by a general partner;
(3) In the case of a sole proprietorship: by the proprietor;
(4) In the case of a municipal, state, or other public entity: by a principal executive officer,
ranking elected official, or other duly authorized employee.
All reports required by the individual permit and other information requested by the Director shall
be signed by a person described above or by a duly authorized representative of that person. A
person is a duly authorized representative only if:
(1) The authorization is made in writing by a person described above;
(2) The authorization specified either an individual or a position having responsibility for the
overall operation of the regulated facility or activity, such as the position of plant
manager, operator of a well or well field, superintendent, a position of equivalent
Part III Page 3 of 8

Permit No. NCS00348
responsibility, or an individual or position having overall responsibility for environmental
matters for the company. (A duly authorized representative may thus be either a named
individual 01 idly itidividunl u(;rul)yiug it named position.); and
(3) The written authorization is submitted to the Director.
Any person signing a document under paragraphs a. or b. of this section shall make the following
certification:
"I certify, under penalty of law, that this document and all attachments were prepared under my
direction or supervision in accordance with a system designed to assure that qualified personnel
properly gather and evaluate the information submitted. Based on my inquiry of the person or
persons who manage the system, or those persons directly responsible for gathering the
information, the information submitted is, to the best of my knowledge and belief, true, accurate,
and complete. I am aware that there are significant penalties for submitting false information,
including the possibility of fines and imprisonment for knowing violations."
4. Individual Permit Modification Revocation and Reissuance or Termination
The issuance of this individual permit does not prohibit the Director from reopening and modifying the
individual permit, revoking and reissuing the individual permit, or terminating the individual permit as
allowed by the laws, rules, and regulations contained in Title 40, Code of Federal Regulations, Parts 122
and 123; Title 15A of the North Carolina Administrative Code, Subchapter 2H .0100; and North Carolina
General Statute 143-215.1 et al.
5. Permit Actions
The permit may be modified, revoked and reissued, or terminated for cause. The notification of planned
changes or anticipated noncompliance does not stay any individual permit condition.
SECTION C: OPERATION AND MAINTENANCE OF POLLUTION CONTROLS
Prover Operation and Maintenance
The permittee shall at all times properly operate and maintain all facilities and systems of treatment and
control (and related appurtenances) which are installed or used by the permittee to achieve compliance with
the conditions of this individual permit. Proper operation and maintenance also includes adequate
laboratory controls and appropriate quality assurance procedures. This provision requires the operation of
back-up or auxiliary facilities or similar systems which are installed by a permittee only when the operation
is necessary to achieve compliance with the conditions of this individual permit.
Need to Halt or Reduce Not a Defense
It shall not be a defense for a permittee in an enforcement action that it would have been necessary to halt or
reduce the permitted activity in order to maintain compliance with the condition of this individual permit.
Bvtrassine of Stormwater Control Facilities
Bypass is prohibited and the Director may take enforcement action against a permittee for bypass unless
a. Bypass was unavoidable to prevent loss of life, personal injury or severe property damage; and
Part III Page 4 of 8

Permit No. NCS00348
There were no feasible alternatives to the bypass, such as the use of auxiliary control facilities,
retention of storrnwater or maintenance during normal periods of equipment downtime or dry
weather. This condition is not satisfied if adequate backup controls should have been installed in
the exercise of reasonable engineering judgment to prevent a bypass which occurred during normal
periods of equipment downtime or preventive maintenance; and
C. The permittee submitted notices as required under, Part III, Section E of this permit.
If the Director determines that it will meet the three conditions listed above, the Director may approve an
anticipated bypass after considering its adverse effects.
SECTION D: MONITORING AND RECORDS
Representative SamDlin
Samples collected and measurements taken, as required herein, shall be characteristic of the volume and
nature of the permitted discharge. Analytical sampling shall be performed during a representative storm
event. Samples shall be taken on a day and time that is characteristic of the discharge. All samples shall be
taken before the discharge joins or is diluted by any other waste stream, body of water, or substance.
Monitoring points as specified in this permit shall not be changed without notification to and approval of
the Director.
Recordine Results
For each measurement, sample, inspection or maintenance activity performed or collected pursuant to the
requirements of this individual permit, the permittee shall record the following information:
a. The date, exact place, and time of sampling, measurements, inspection or maintenance activity;
b. The individual(s) who performed the sampling, measurements, inspection or maintenance activity;
C. The date(s) analyses were performed;
d. The individual(s) who performed the analyses;
e. The analytical techniques or methods used; and
f. The results of such analyses.
Flow Measurements
Where required, appropriate flow measurement devices and methods consistent with accepted scientific
practices shall be selected and used to ensure the accuracy and reliability of measurements of the volume of
monitored discharges.
Test Procedures
Test procedures for the analysis of pollutants shall conform to the EMC regulations published pursuant to
NCGS 143-215.63 et. seq, the Water and Air Quality Reporting Acts, and to regulations published pursuant
to Section 304(g), 33 USC 1314, of the Federal Water Pollution Control Act, as Amended, and Regulation
40 CFR 136.
Part III Page 5 of 8

Permit No. NCS00348
To meet the intent of the monitoring required by this individual permit, all test procedures must produce
minimum detection and reporting levels and all data generated must be reported down to the minimum
detection or lower reporting level of the procedure.
Representative Outfall
If a facility has multiple discharge locations with substantially identical stormwater discharges that are
required to be sampled, the permittee may petition the Director for representative outfall status. If it is
established that the stormwater discharges are substantially identical and the permittee is granted
representative outfall status, then sampling requirements may be performed at a reduced number of outfalls.
6. Records Retention
Visual monitoring shall be documented and records maintained at the facility along with the Stormwater
Pollution Prevention Plan. Copies of analytical monitoring results shall also be maintained on -site. The
permittee shall retain records of all monitoring information, including all calibration and maintenance
records and all original strip chart recordings for continuous monitoring, instrumentation, and copies of all
reports required by this individual permit for a period of at least 5 years from the date of the sample,
measurement, report or application. This period may be extended by request of the Director at any time.
Insnection and Entry
The permittee shall allow the Director, or an authorized representative (including an authorized contractor
acting as a representative of the Director), or in the case of a facility which discharges through a municipal
separate storm sewer system, an authorized representative of a municipal operator or the separate storm
sewer system receiving the discharge, upon the presentation of credentials and other documents as may be
required by law, to;
a. Enter upon the permittee's premises where a regulated facility or activity is located or conducted,
or where records must be kept under the conditions of this individual permit;
b. Have access to and copy, at reasonable times, any records that must be kept under the conditions of
this individual permit;
C. Inspect at reasonable times any facilities, equipment (including monitoring and control equipment),
practices, or operations regulated or required under this individual permit; and
d. Sample or monitor at reasonable times, for the purposes of assuring individual permit compliance
or as otherwise authorized by the Clean Water Act, any substances or parameters at any location.
SECTION E: REPORTING REQUIREMENTS
Discharge Monitoring Reports
Samples analyzed in accordance with the terms of this permit shall be submitted to the Division on
Discharge Monitoring Report (DMR) forms provided by the Director. Submittals shall be delivered to the
Division no later than 30 days from the date the facility receives the sampling results from the laboratory.
When no discharge has occurred from the facility during the report period, the permittee is required to
submit a discharge monitoring report within 30 days of the end of the three-month sampling period, giving
all required information and indicating "NO FLOW" as per NCAC T15A 02B .0506.
Part III Page 6 of 8

Permit No. NCS00348
The permittee shall record the required qualitative monitoring observations on the SDO Qualitative
Monitoring Report (QMR) form provided by the Division, and shall retain the completed forms on site..
Qualitative monitoring results should not be submitted to the Division, except upon DWQ's specific
requirement to do so.
Submitting Reports
Duplicate signed copies of all reports required herein, shall be submitted to the following address:
Division of Water Quality
Surface Water Protection Section
ATTENTION: Central Files
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
In addition, a separate signed Annual Summary DMR copy shall be submitted to the permittee's DWQ
Regional Office (RO) by March 1 of each year.
3. Availability of Reports
Except for data determined to be confidential under NCGS 143-215.3(a)(2) or Section 308 of the Federal
Act, 33 USC 1318, all reports prepared in accordance with the terms shall be available for public inspection
at the offices of the Division of Water Quality. As required by the Act, analytical data shall not be
considered confidential. Knowingly making any false statement on any such report may result in the
imposition of criminal penalties as provided for in NCGS 143-215.613 or in Section 309 of the Federal Act.
4. Non-Stormwater Discharges
If the storm event monitored in accordance with this individual permit coincides with a non-stormwater
discharge, the permittee shall separately monitor all parameters as required under the non-stormwater
discharge permit and provide this information with the stormwater discharge monitoring report.
Planned Changes
The permittee shall give notice to the Director as soon as possible of any planned changes at the permitted
facility which could significantly alter the nature or quantity of pollutants discharged. This notification
requiheinent includes pollutants which are not specifically listed in the individual pennit or subject to
notification requirements under 40 CFR Part 122.42 (a).
6. Anticipated Noncompliance
The permittee shall give notice to the Director as soon as possible of any planned changes at the permitted
facility which may result in noncompliance with the individual permit requirements.
Bypass
a. Anticipated bypass. If the permittee knows in advance of the need for a bypass, it shall submit
prior notice, if possible at least ten days before the date of the bypass; including an evaluation of
the anticipated quality and affect of the bypass.
Unanticipated bypass. The permittee shall submit notice within 24 hours of becoming aware of an
unanticipated bypass.
Part III Page 7 of 8

Permit No. NCS00348
Twenty-four Hour Reporting
The permitteo shall report to the central office or the appropriate regional office any noncompliance which
may endanger health or the environment. Any information shall be provided orally within 2.4 hours from
the time the permittee became aware of the circumstances. A written submission shall also be provided
within 5 days of the time the permittee becomes aware of the circumstances.
The written submission shall contain a description of the noncompliance, and its causes; the period of
noncompliance, including exact dates and times, and if the noncompliance has not been corrected, the
anticipated time compliance is expected to continue; and steps taken or planned to reduce, eliminate, and
prevent reoccurrence of the noncompliance.
The Director may waive the written report on a case -by -case basis if the oral report has been received
within 24 hours.
9. Other Noncompliance
The permittee shall report all instances of noncompliance not reported under 24 hour reporting at the time
monitoring reports are submitted.
10. Other Information
Where the permittee becomes aware that it failed to submit any relevant facts in an application for an
individual permit or in any report to the Director, it shall promptly submit such facts or information.
Part III Page 8 of 8

NCS000348
PART IV LIMITATIONS REOPENER
This individual permit shall be modified or alternatively, revoked and reissued, to comply with any applicable
effluent guideline or water quality standard issued or approved under Sections 302(b) (2) (c), and (d), 304(b) (2) and
307(a) of the Clean Water Act, if the effluent guideline or water quality standard so issued or approved:
a. Contains different conditions or is otherwise more stringent than any effluent limitation in the individual
permit; or
Controls any pollutant not limited in the individual permit.
The individual permit as modified or reissued under this paragraph shall also contain any other requirements in the
Act then applicable.
PART V ADMINISTERING AND COMPLIANCE MONITORING FEE
REQUIREMENTS
The permittee must pay the administering and compliance monitoring fee within 30 (thirty) days after being billed by
the Division. Failure to pay the fee in timely manner in accordance with 15A NCAC 2H .0105(b)(4) may cause this
Division to initiate action to revoke the individual permit.
PART VI DEFINITIONS
1. Act
See Clean Water Act.
Arithmetic Mean
The arithmetic mean of any set of values is the summation of the individual values divided by the number of
individual values.
Allowable Non-Stormwater Discharges
This permit regulates stormwater discharges. Non-stormwater discharges which shall be allowed in the
stormwater conveyance system are:
(a) All other discharges that are authorized by a non-stormwater NPDES permit.
(b) Uncontaminated groundwater, foundation drains, air -conditioner condensate without added
chemicals, springs, discharges of uncontaminated potable water, waterline and fire hydrant
flushings, water from footing drains, flows from riparian habitats and wetlands.
(c) Discharges resulting from fire -fighting or fire -fighting training.
Best Management Practices (BMPs)
Measures or practices used to reduce the amount of pollution entering surface waters. BMPs may take the
form of a process, activity, or physical structure.
Parts IV, V and VI Page 1 of 5

Permit No. NCS00348
Bypass
A bypass is the known diversion of stormwater from any portion of a stormwater control facility including
the collection system, which is not a designed or established operating mode for the facility.
6. Bulk Storage of Liquid Products
Liquid raw materials, manufactured products, waste materials or by-products with a single above ground
storage container having a capacity of greater than 660 gallons or with multiple above ground storage
containers located in close proximity to each other having a total combined storage capacity of greater than
1,320 gallons.
7. Clean Water Act
The Federal Water Pollution Control Act, also known as the Clean Water Act (CWA), as amended, 33
USC 1251, et. seq.
8. Division or DWO
The Division of Water Quality, Department of Environment and Natural Resources.
9. Director
The Director of the Division of Water Quality, the permit issuing authority.
10. EMC
The North Carolina Environmental Management Commission.
11. Grab Sample
An individual sample collected instantaneously. Grab samples that will be directly analyzed or qualitatively
monitored must be taken within the first 30 minutes of discharge.
12. Hazardous Substance
13.
Any substance designated under 40 CFR Part 116 pursuant to Section 311 of the Clean Water Act.
A disposal facility or part of a disposal facility where waste is placed in or on land and which is not a land
treatment facility, a surface impoundment, an injection well, a hazardous waste long-term storage facility or
a surface storage facility.
14. Municipal Separate Storm Sewer System
A stormwater collection system within an incorporated area of local self-government such as a city or town.
15. No Exposure
A condition of no exposure means that all industrial materials and activities are protected by a storm
resistant shelter or acceptable storagc containers to prevent exposure to rain, snow, snowinelt, of runoff.
Industrial materials or activities include, but are not limited to, material handling equipment or activities,
Part VI Page 2 of 5 Pages

Permit No. NCS00348
industrial machinery, raw materials, intermediate products, by-products, final products, or waste products.
DWQ may grant a No Exposure Exclusion from NPDES Stormwater Permitting requirements only if a
facility complies with the terms and conditions described in 40 CFR § 1?? ?6(g)
16. Overburden
Any material of any nature, consolidated or unconsolidated, that overlies a mineral deposit, excluding
topsoil or similar naturally -occurring surface materials that are not disturbed by mining operations.
17. Permittee
The owner or operator issued a permit pursuant to this individual permit.
18. Point Source Discharge of Stormwater
Any discernible, confined and discrete conveyance including, but not specifically limited to, any pipe, ditch,
channel, tunnel, conduit, well, or discrete fissure from which stormwater is or may be discharged to waters
of the state.
19. Representative Storm Event
A storm event that measures greater than 0.1 inches of rainfall and that is preceded by at least 72 hours in which no
storm event measuring greater than 0.1 inches has occurred. A single storm event may contain up to 10 consecutive
hours of no precipitation. For example, if it rains for 2 hours without producing any collectable discharge, and then
stops, a sample may be collected if a rain producing a discharge begins again within the next 10 hours.
20. Representative Outfall Status
When it is established that the discharge of stormwater runoff from a single outfall is representative of the
discharges at multiple outfalls, the DWQ may grant representative outfall status. Representative outfall
status allows the permittee to ;perform analytical monitoring at a reduced number of outfalls.
21. Rinse Water Discharge
The discharge of rinse water from equipment cleaning areas associated with industrial activity. Rinse
waters from vehicle and equipment cleaning areas are process wastewaters and do not include washwaters
utilizing any type of detergent or cleaning agent.
22. Secondary Containment
Spill containment for the contents of the single largest tank within the containment structure plus sufficient
freeboard to allow for the 25-year, 24-hour storm event.
23. Section 313 Water Priority Chemical
A chemical or chemical category which:
a. Is listed in 40 CFR 372.65 pursuant to Section 313 of Title III of the Superfund Amendments and
Reauthorization Act (SARA) of 1986, also titled the Emergency Planning and Community Right -
to -Know Act of 1986;
b. Is present at or above threshold levels at a facility subject to SARA Title III, Section 313 reporting
requirements; and
C. That meets at least one of the following criteria:
Part VI Page 3 of 5 Pages

Permit No. NCS00348
(1) is listed in Appendix D of 40 CPR part 122 on I able if (organic priority pollutants),
Table III (cei tain inetals, cyanides, and phenols), of Table IV (cei Will toxic 1ollutants and
hazardous substances);
(2) Is listed as a hazardous substance pursuant to section 311(b)(2)(A) of the CWA at 40
CFR 116.4; or
(3) Is a pollutant for which EPA has published acute or chronic water quality criteria.
24. Severe Property Damage
Means substantial physical damage to property, damage to the control facilities which causes them to
become inoperable, or substantial and permanent loss of natural resources which can reasonably be
expected to occur in the absence of a bypass. Severe property damage does not mean economic loss caused
by delays in production.
25. Significant Materials
Includes, but is not limited to: raw materials; fuels; materials such as solvents, detergents, and plastic
pellets; finished materials such as metallic products; `raw materials used in food processing or production;
hazardous substances designated under section 101(14) of CFRCi.A; any chemical the facility is required to
report pursuant to section 313 of Title III of SARA; fertilizers; pesticides; and waste products such as ashes,
slag and sludge that have the potential to be released with stormwater discharges.
26. Significant Spills
Includes, but is not limited to: releases of oil or hazardous substances in excess of reportable quantities
under section 311 of the Clean Water Act (Ref: 40 CFR 110.10 and CFR 117.21) or section 102 of
CERCLA (Ref: 40 CFR 302.4).
27. Stormwater Runoff
The flow of water which results from precipitation and which occurs immediately following rainfall or as a
result of snowmelt.
28. Stormwater Associated with Industrial Activity
The discharge from any point source which is used for collecting and conveying stormwater and which is
directly related to manufacturing, processing or raw material storage areas at an industrial site Facilities
considered to be engaged in "industrial activities" include those activities defined in 40 CFR 122.26(b)(14).
The term does not include discharges from facilities or activities excluded from the NPDES program.
29. Stormwater Pollution Prevention Plan
A comprehensive site -specific plan which details measures and practices to reduce stormwater pollution and
is based on an evaluation of the pollution potential of the site.
30. Ten Year Design Storm
The maximum 24 hour precipitation event expected to be equaled or exceeded on the average once in ten
years. Design storm information can be found in the State of North Carolina Erosion and Sediment Control
Plamiing and Design Manual.
Part VI Page 4 of 5 Pages

Permit No. NCS00348
J I. I olal Mow
The flow corresponding to the time period over which the entire storm event occurs. Total flow shall be
either; (a) measured continuously, (b) calculated based on the amount of area draining to the outfall, the
amount of built -upon (impervious) area, and the total amount of rainfall, or (c) estimated by the
measurement of flow at 20 minute intervals during the rainfall event.
32, Total Maximum Daily Load (TMDL)
A TMDL is a calculation of the maximum amount of a pollutant that a waterbody can receive and still meet
water quality standards, and an allocation of that amount to the pollutant's sources. A TMDL is a detailed
water quality assessment that provides the scientific foundation for an implementation plan. The
implementation plan outlines the steps necessary to reduce pollutant loads in a certain body of water to
restore and maintain water quality standards in all seasons. The Clean Water Act, Section 303, establishes
the water quality standards and TMDL programs.
33. Toxic Pollutant
Any pollutant listed as toxic under Section 307(a)(1) of the Clean Water Act.
34. Upset
Means an exceptional incident in which there is unintentional and temporary noncompliance with
technology based permit effluent limitations because of factors beyond the reasonable control of the
permittee. An upset does not include noncompliance to the extent caused by operational error, improperly
designed treatment or control facilities, inadequate treatment or control facilities, lack of preventive
maintenance, or careless or improper operation.
35. Vehicle Maintenance Activity
Vehicle rehabilitation, mechanical repairs, painting, fueling, lubrication, vehicle cleaning operations, or
airport deicing operations.
36. Visible Sedimentation
Solid particulate matter, both mineral and organic, that has been or is being transported by water, air,
gravity, or ice from its site of origin which can be seen with the unaided eye.
37. 25-year, 24 hour storm event
The maximum 24-hour precipitation event expected to be equaled or exceeded, on the average, once in 25
years.
Part VI Page 5 of 5 Pages

N.C. Division of Water Quality, Stormwater and General Permits Unit
Facility Name: PRIMARY ENERGY - SOUTHPORT FACILITY
Permit Number: NCS000348
Location Address: 1281 POWERHOUSE DR SE
SOUTHPORT, NC 28461
County: BRUNSWICK
"I certify, under penalty of law, that the Stormwater Pollution Prevention Plan (SPPP) document and all attachments
were developed and implemented under my direction or supervision in accordance with a system designed to assure
that qualified personnel properly gather and evaluate the information required by the SPPP. Based on my inquiry of
the person or persons who manage the system, or those persons directly responsible for gathering the information,
the information gathered is, to the best of my knowledge and belief, tme, accurate, and complete"
"I certify that the SPPP has been developed, signed and retained at the facility location and the SPPP has been fully
implemented at the named facility location in accordance with the terms and conditions of the stormwater general
permit."
"I am aware that there are significant penalties for falsifying information, including the possibility of fines and
imprisonment for knowing violations"
Sign (according to permit signatory requirements) and return this Certification. DO NOT SEND THE
STORMWATER POLLUTION PREVENTION PLAN WITH THE CERTIFICATION.
Signature � • Date 10//23/06
GARY R HICKEY GENERAL MANAGER
Print or type name of person signing above Title
SPPP Cerlilication 2199

°�WATF9vg PERMIT COVERAGE
RENEWAL APPLICATION FORM Permit
Number
National Pollutant Discharge Elimination System
Stormwater Discharge Permit
THIS APPLICATION MUST BE SIGNED AND RETURNED ALONG WITH THE REQUESTED SUPPLEMENTAL
INFORMATION TO THE DIV. OF WATER QUALITY IN ORDER FOR YOUR FACILITY TO QUALIFY FOR
RENEWAL OF YOUR STORMWATER PERMIT NCS000348
The following is the information currently in our database for your facility. Please review this information carefblly
and make all corrections as necessary in the space provided to the right of the current information.
OWNER INFORMATION
Owner/Org. Name: PRIMARY ENERGY OF NORTH CAROLINA LLC -SOUTHPORT
Owner Contact:
Gary R Hickey -
Mailing Address:
P O Box 10836
Southport, NC 28461
Phone Number:
[phone]
Fax Number:
[phone]
E-mail address:
ghickey(c primaryenergy.com
FACILITY INFORMATION
Facility Name: PRIMARY ENERGY - SOUTHPORT FACILITY
Facility Contact:
Facility Address: 1281 COGENTIUX DR SE
. 28461
Phone Number:
Fax Number:
E-mail address:
PERMIT INFORMATION
Permitcontact: TERRYBAKER
Mailing Address: PO BOX 10836
SOUTHPORT, NC 28461
Phone Number: 9104575056
Fax Number:
E-mail address:
DISCHARGE INFORMATION
Discharge Receiving; Water:
Stream Class:
Basin:
Sub -Basin #:
Number of outfalls:
CERTIFICATION
Gary R I Iickey
1281 Powerhouse Drive SE
Southport, NC 28461
[phone]
[phone]
ghickev(c. primaryenergy.com
GARY R HICKEY
[phone]
ghickev(a)brimarvenergy.com
BSEP DISCIIARGE CANAL
ATLANTIC OCEAN
SIX
I certify that I am familiar with the information contained in the application and that to the best of my knowledge and
belief such inform at' n is true, complete and accurate.
Signature Jf�jJ Date 10/23/06
GARY R HICKEY General Manager
Print or type name of person signing above
Please return this completed renewal application form to:
Individual Permit Renewal
Attn: Mr. Mike Randall
Stormwater and General Permits Unit
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
Title

SUPPLEMENTAL INFORMATION REQUIRED FOR RENEWAL OF INDIVIDUAL NPDES
STORM WATER PERMIT
Two copies of each of the following shall accompany this submittal in order for the application to be
considered complete:
(Do ret submit the site Stormwater Pollution Prevention Plan)
Initials
GW 1. A current Site Map from the Stormwater Pollution Prevention Plan. The location of
industrial activities (including storage of materials, disposal areas, process areas and
loading and unloading areas), diainagestiuctuies, drainage areas for each outfall, building
locations and impervious surfaces should be clearly noted.
GW 2. A summary of Analytical Monitoring results during the term of the existing permit (if your
permit required analytical sampling). Do not submit individual lab reports. The summary
can consist of a table including such items ashoutfall number, parameters sampled, lab
results, date sampled, and storm event data.
G W 3. A summary of the Visual Monitoring results. Do not submit individual monitoring reports.
The summary can consist of a table including such items as outfall number, parameters
surveyed, observations, and date monitoring conducted.
GW 4. A summary of the Best Management Practices utilized at the permitted facility. Summary
should consist of a short narrative description of each BMP's in place at the facility. If the
implementation of any BMP's is planned, please include information on these BMP's.
GW 5. A short narrative describing any significant changes in industrial activities at the permitted
facility Significant changes could include the addition or deletion of work processes,
changes in material handling practices, changes in material storage practices, andlor
changes in the raw materials used by the facility.
GW 6. Certification of the development and implementation of a Stormwater Pollution Prevention
Plan for the permitted facility (Sign and return attached form).
If the final year analytical monitoring of the existing permit term has not been completed
prior to filing the renewal submittal, then the last years monitoring results should be
submitted within 30 days of receipt of the laboratory reports. (i.e. do not withhold renewal
submittal waiting on lab results)
Representative storm sampling may now be conducted anytime during the year (the April to
November window has been eliminated) and the representative rainfall event is now
defined as a storm event that measures greater than 0.1 inches and is preceded by at least 72
hours in which no storm event measuring greater than 0.1 inches has occurred.

Primary Energy - Southport Facility
. r AN.ALYTI�L MQNITC)RING UM1tllARY.,
,
�NCHs,
nnuTs, ;n; , tINIII
1
12/05/02
0.15
130
0.011 1
25
I
11/19/03
1.40
309
0.095 27
<20
1
09/14/04
2.00
330
0.136 2
<20
1
05/05/05
3.90
1280
0.265 1
17
1
10/05/05
0.11
91
0.012 7
24
1
01/14/06
0.50
210
0.055 37
48
1
04/17/06
0.80
15d-7
0.087 3
17

cn
0
.a
0
Iq
2)
0
I<

8.2.3 BMP Summary
Table S.1 below summarizes the 1 A41's used at the Southport I'lant.
Potentially exposed materials at the Primary Energy plant include coal, petroleum products stored in
existing ASTs, water treatment chemicals, and ash. Coal for the boiler plant is stored outside in the coal
pile and coal pile runoff is treated in the low volume wastewater system prior to discharge (i.e., it is not
drained to the storm water system). Coal is brought in by rail at the west end of the plant and unloaded
daily through the coal chute and transported via conveyor belt to the coal pile. The risk of coal dust
entering the storm water via fugitive dust exists and minimize that risk, coal unloading BMPs are used and,
because the drainage from the DA 1 area is through vegetative buffers, the quantity of coal reaching the
receiving water is minimal. Water is sprayed onto the coal as it is unloaded from the rail cars in one of the
coal unloading BMPs. Also, coal dust from the edges of the chute where coal is deposited is swept up daily
after unloading operations. These BMPs, coupled with the comparatively limited surface area draining to
the storm water system in the western plant site, minimize fugitive dust transport.
The risk of the petroleum products entering the storm system is low due to the use of secondary
containment that conforms to 40 CFR 112.8(c)(2) and non-structural controls (e.g., routine inspections) to
prevent spills. Used kerosene is stored in a 250-gallon aboveground storage tank (AST) located at the
Drum Storage Area. Safety Kleen removes the used oil as needed. Diesel is stored in a 300-gallon AST
inside the Demineralizer Building and in a 1,000-gallon AST located within the Rail Car Unloading Area
secondary containment. Quarles supplies Primary Energy with diesel as needed. There are dedicated
unloading bays at each location.
Chemical storage and usage is limited to the Demineralizer Building area and the RO Building area. The
several chemical storage units in the Demineralizer Building are all equipped with secondary containment
and, any spills are routed to the Neutralization Tank and then the Wastewater Basin for treatment. A spill
kit is located inside the water treatment building. There is a dedicated unloading bay at the Demineralizer
Building. The chemicals used in the RO Building are stored a chemical skid on the floor in the building.
The floor is sloping towards a drain that discharges into the chemical sump from the Demineralizer
Building.
The risk of ash or ash residue entering the storm system is low due to the use of dikes and non-structural
controls (i.e. curtain). As the truck enters the ash loading area, a curtain is dropped from the ceiling of the
ash loading area to the ground. This procedure minimizes fugitive dust due to the ash loading. When the
ash loading is complete, the ash loading area floor is thoroughly hosed down to minimize the tracking of
ash residue. The ash loading areas are located in the western portion of Drainage Area 5. and as such. are
treated at the onsite waste water treatment plant.

Integrated SPCC/SWPPP
Primary Energy of NC, LLC - Southport Plant
Table 8-1 inventory of Materials Exposed to Precipitation
�f p>S#�_e�
2 5",
�,� i'E
, .., � r �� _�'�-ra`z' z;. 3'
u' [S ','S`3✓' l .;E
s. � � `'�`,c� '� e: y£� s��� v'S�-`"'✓
"%" aE r:y 2'S liwU .; 5e y;�r5""£i`s✓
�3� .,. .t`' `tyS, �;
y 3 f 4 .£ '`v^iu^.^Sx
?r ���`1 c� //": �lc�
,n Y2 .£L ;a1/gyp i +Y :k C/y �`e' ry,.��l .i'i�
DA 1 —adjacent to rail
Coal (de minimus)
Good housekeeping BMPs for
Overland flow
spur
rail car unloading
DA2 — adjacent to rail
Coal (de minimus)
Good housekeeping BMPs for
Overland flow
spur
rail car unloading
DA3
None.
None.
None.
DA4 — Demineralizer
None.
None.
None.
Building
DA4 — Point -of -Fill Tote
Proprietary water treatment
Secondary containment with
None.
chemicals (1,000-gal
discharge routed to
capacity)
Wastewater Basin
DA4 — Electric Fire
Transformer oil (125-gal
Secondary containment with
None.
Pump Transformer
capacity)
discharge to Wastewater Basin
DA4 — Materials
None.
Containment with direct
None.
Transfer Bay (at
drainage to Wastewater Basin
Demineralizer Building)
DA4 — Rail Car
Diesel fuel (1,000-gal
Secondary containment with
None.
Unloading Area
capacity); Transformer oil
INSPECTION then discharge to
Secondary Containment
(990-gal capacity)
Storm water system
DA4 — Drum Storage
Used kerosene (250-gal
Secondary containment with
None.
Area
capacity)
INSPECTION then discharge to
Storm water system
DA4 — Laydown Area
Iron/steel equipment and
None.
None.
wood packing materials
(quantity varies)
DA5 — Transformer
Transformer oil (2 at 9,170-
Gravity discharge to Oil Trap
None.
Yards
gal and 2 at 990-gal capacity)
Pit
DA5 — Oil Trap Pit
Typically none (13,125-gal
Gravity discharge to
None.
capacity)
Wastewater Basin
DA5 --- Slaker, Ash Silos,
Fly ash and/or Lime
Gravity discharge to
None.
and ash handling area
(indeterminate)
Wastewater Basin
DA5 — TDF Storage Yard
TDF (>1,000 tons)
Gravity discharge to
None.
Wastewater Basin
DA6 — Switching Yard
Sulfur hexafluoride — gas
None.
None.
DA7
None.
None.
None.
DA8 — near Coal
Coal (de minimus)
Good housekeeping BMPs for
Overland flow
Conveyor
area beneath conveyor
DA9 — Coal Pile
Coal (>1,000 tons)
Gravity discharge to
None.
Wastewater Basin
DA10
None.
None.
None.

Significant Changes in Industrial Activities
In 2006 the Yrunary Energy Southport Facility added unadulterated wood as an alternative fuel and an RO
building to produce raw water.
The wood is stored in a dedicated storage bin which directs rain runoff to the waste treatment basin via a
vee ditch. Transfer to the blending area is short (less than 50 yds) which minimizes any stormwater
contamination from the transfer process.
Chemical storage and usage in the RO Building area consist of Sodiumm Hypochlorite and coagulant
injections to well water. The dissolved iron in the well water reacts with the Sodium Hypochlorite is then
filtered by multimedia filters prior to purification by the RO unit. The chemicals used in the RO Building
are stored in a chemical skid on the floor in the building. The floor is sloping towards a drain that
discharges into the chemical sump from the Demineralizer Building.

STORMWAIRR POLLUTION PREVENTION PLAN
N.C. Division of Water Quality, Stormwater and General Permits Unit
Facility Name: PRIMARY ENERGY - SOUTHPORT FACILITY t
Permit Number: NCS000348
Location Address: 1281 POWERHOUSE DR SE
SOUTHPORT, NC 28461 {
County: BRUNSWICK
"I certify, under penalty of law, that the Stormwater Pollution Prevention Plan (SPPP) document and all ents
were developed and implemented under my direction or supervision in accordance with a system design as
that qualified personnel properly gather and evaluate the information required by the SPPP. Based on my i uiry of
the person or persons who manage the system, or those persons directly responsible for gathering the information,
the information gathered is, to the best of my knowledge and belief, tine, accurate, and complete"
"I certify that the SPPP has been developed, signed and retained at the facility location and the SPPP has been fully
implemented at the named facility location in accordance with the terms and conditions of the stormwater general
permit."
"I am aware that there are significant penalties for falsifying information, including the possibility of fines and
imprisonment for knowing violations"
Sign (according to permit signatory requirements) and return this Certification. DO NOT SEND THE
STORMWATER POLLUTION PREVENTION PLAN WITH THE CERTIFICATION.
Signature
i I
Date 10//23/06
-2e t, &kGARY R HICKEY GENERAL MANAGER
Print or type name of person signing above Title
SPPP Cerlilicalion 2199

°�W �rF9vc PERMIT COVERAGE
g RENEWAL APPLICATION FORM Permit Number
National Pollutant Discharge Elimination System NCS000348
Stormwater Discharge Permit
THIS APPLICATION MUST BE SIGNED AND RETURNED ALONG WITH THE REQUESTED SUPPLEMENTAL
INFORMATION TO THE DIV. OF WATER QUALITY IN ORDER FOR YOUR FACILITY TO QUALIFY FOR
RENEWAL OF YOUR STORMWATER PERMIT NCS000348
The following is the information currently in our database for your facility. Please review this information carefblly
and make all corrections as necessary in the space provided to the right of the current information.
OWNER INFORMATION
Owner/Org. Name: PRIMARY ENERGY OF NORTH CAROLINA LLC - SOUTHPORT
Owner Contact:
Gary R Hickey
Mailing Address.
P O Box 10836
Southport, NC 28461
Phone Number:
[phone]
Fax Number:
[phone]
E-mail address:
ghickey r primatyenergy.com
FACILITY INFORMATION
Facility Name: PRIMARY ENERGY - SOUTHPORT FACILITY
b acility Contact: Gary R Hickey
Facility Address: 1281 COGENTIUX DR SE 1281 Powerhouse Drive SE
28461 Southport, NC 28461
Phone Number: [phone]
Fax Number: [phone]
E-mail address: ghickeyCaprimaryenergy.com
PERMIT INFORMATION
Permitcontact: TERRYBAKER
Mailing Address: PO BOX 10836
SOUTHPORT, NC 28461
Phone Number: 9104575056
Fax Number:
E-mail address:
DISCHARGE INFORMATION
Discharge Receiving Water:
Stream Class:
Basin:
Sub -Basin #:
Number of outfalls:
CERTIFICATION
GARY R HICKEY
[phone]
hg ickev cr primaryenergy.com
BSEP DISCHARGE CANAL
ATLANTIC OCEAN
I certify that I am familiar with the information contained in the application and that to the best of my knowledge and
belief such informat' is true, complete and accurate.
L
Signature Date 10/23/06
GARY R HI EY General Manager
Print or type name of person signing above Title
Please return this completed renewal application form to:
Individual Permit Renewal
Attn: Mr. Mike Randall
Stormwater and General Permits Unit
1617 Mail Service Center
Raleigh, North Carolina 27699-1617

SITPPI,FMFNTAI, INFORMATION RFQITIRFD FOR RFNFWAI,OF INDIVIDUAL NPDFS
STORM WATER PERMIT
TWO copies of each of the following shall accompany this submittal in order for the application to be
considered complete:
(Do tat submit the site Stormwater Pollution Prevention Plan)
Initials
GIA/ 1. A current Site Map from the StormwaterPollution Prevention Plan The location of
industrial activities (including storage of materials, disposal areas, process areas and
loading and unloading areas), drainage structures, drainage areas for each outfall, building
locations and impervious surfaces should be clearly noted.
GW 2. A summary of Analytical Monitoring results during the term of the existing permit (if your
permit required analytical sampling). Do not submit individual lab reports. The summary
can consist of a table including such items ashoutfall number, parameters sampled, lab
results, date sampled, and storm event data.
G W 3. A summary of the Visual Monitoring results. Do not submit individual monitoring reports.
The summary can consist of a table including such items as outfall number, parameters
surveyed, observations, and date monitoring conducted.
GW 4. A summary of the Best Management Practices utilized at the permitted facility. Summary
should consist of a short narrative description of each BMP's in place at the facility. If the
implementation of any BMP's is planned, please include information on these BMP's.
GW 5. A short narrative describing any significant changes in industrial activities at the permitted
facility Significant changes could include the addition or deletion of work processes,
changes in material handling practices, changes in material storage practices, andlor
changes in the raw materials used by the facility.
GW 6. Certification of the development and implementation of a Stormwater Pollution Prevention
Plan fur the perntted facility (Sign and return attached form).
If the final year analytical monitoring of the existing permit term has not been completed
prior to filing the renewal submittal, then the last years monitoring results should be
submitted within 30 days of receipt of the laboratory reports. (i.e. do not withhold renewal
submittal waiting on lab results)
Representative storm sampling may now be conducted anytime during the year (the April to
November window has been eliminated) and the representative rainfall event is now
defined as a storm event that measures greater than 0.1 inches and is preceded by at least 72
hours in which no storm event measuring greater than 0.1 inches has occurred.

EPCOR USA - Stormwater Permit Renewal Information
s
Subject: EPCOR USA - Stormwater Permit Renewal Information
From: "Moore, James" <[e-mail]>
Date: Wod, 10 Doc 2008 10:41:47 -0600
To: -Briun.Lowthereamemail.not-
CC: "Thorley, Tom" <[e-mail]>, "Androskaut, Larry" <[e-mail]>,
"Gibbs, Bob" <[e-mail]>, "Stubbs, Paul" <[e-mail]>, "Wagoner, Greg"
<[e-mail]>, "Hermanson, David" <[e-mail]>, "Cameron Weaver"
<Cameron. [e-mail]>
Mr. Brian Lowther
NCDENR Water Quality Division
Stormwater Permitting Section
Brian:
Our North Carolina Project leas changed fioin [lie oiiginul design basis. This email is to provide you with an
update to the project scope per your request.
Our Schedule is to submit the Southport Costal Stormwater Permit to you by January 23rd 2009. It is our
understanding that your department has 60-days from determination of application completeness to issue the
permit. This timeframe is crucial for us as we will begin our project work in March of 2009. We are looking
forward to working with you in your review of the Southport Costal Stormwater Permit.
If you would - please comment on the project work we can conduct on -site prior to issuance of the stonmwater
permit. It is our understanding that we are allowed to begin construction work that does not impact existing
permitted stormwater controls.
Please let me know if you have any questions.
Jim
Project's Overview:
§ Official Name is the North Carolina Emissions Control Project
§ The Project will spend approximately $75MM at our Roxboro and Southport Plants
§ The Project will modify our boilers and fuel handling systems
Boiler modifications will involve addition of a Mobotech overfired air system upgrade and new fuel
feed hoppers
Fuel Handling system modifications will involve addition of a truck dumper, fuel conveyor and pad
storage systems
Prior Project Planning involving installation of a ammonia injection system has been cancelled
Prior Project Planning involving the installation of a S02 solid adsorbent injection has been cancelled
§ No new Fuels or Chemicals will be introduced as part of the project
§ Plant operations will remain the same regarding power generation
Southport Plant - Project Stormwater Impact:
§ The Southport Plant will add a new 40,000 ft.2 fael storage pad
§ Addition of a truck dumper & Motor Control Center - approximately 1800 112
§ The Southport Plant is proposing to add a new 1.5 mile new access roadway to the plant site
§ Total NEW impervious surface area is at approximately 1.63 acres
of 4 1 /26/2009 8:21 AM

EPCOR USA - Stormwater Permit Renewal Information
New Fuel pad area will be directed to the Plant wastewater basins ( wet detention basins ) which
discharge under a NPDES Permit #NC0065099. NPDES permit TSS limits will apply to the treated
water discharged from the plant.
New Roadway will be designed with adjacent "inflltiatioti - conveyance ditches to manage
stormwater. The ditches will connect to the existing stoinawater ditch system which conveys water to
the Progress Energy Brunswick Cooling Water Canal
Roxboro Plant - Project Stormwater Impact:
§ The Roxboro Plant will add a new 16,000 ft.2 fuel storage pad
§ Addition of a truck dumper & Motor Control Center - approximately 1800 ft2
§ The Roxboro Plant is proposing to add a 1/2 mile new access roadway on the plant site
§ Total NEW impervious surface area is at approximately 2.1 acres
New Fuel pad area will be directed to the Plant wastewater basins ( wet detention basins ) which
discharge under a NPDES Permit #NC0065085
New Roadway will be designed with culverts for stormwater runoff to the existing on -site drainage
system
The Army Corp of Engineers ( Mr. Eric Alsmeyer ) is providing a 401 and 404 determination for this
stormwater conveyance.
Southport Stormwater Permits:
§ Southport
submitted a stormwater renewal application in October of 2006 to renew its SW Permit #NCS000348
§ Permit #NCS000348 is expired and Southport is operating under its permit shield
§ Southport is located in a MS4 Coastal region
§ With the Project disturbance of>1 acre - Southport is required to submit for a "Costal" Stormwater
Permit
As part of the Coastal Stormwater Permit Application, a Erosion and Sedimentation Plan is being
developed for submittal with the SW Permit application
§ Our schedule is to submit the Southport E&S and SW applications by January 23rd
Roxboro Stormwater Permit:
Roxboro submitted a stormwater renewal application in October of 2006 to renew its SW Permit
#NCS000347
Permit #NCS000347 is expired and Roxboro also is operating under its permit shield
As Roxboro is NOT in a coastal region - it will not be submitting a new stormwater permit
application
As the Project will be disturbing >1 acre, a Erosion & Sedimentation Plant will be submitted for
Roxboro
§ Roxboro will adjust it Stormwater Management Plan to reflect the plant changes
§ Our schedule is to submit the Roxboro E&S application by January 23rd
Jim
— � Ca, JkV,,A0^ —� tlll _1 Ct u�t.�tks
James C. Moore
Corporate Director EHS, EPCOR USA
2 of 1/26/2009 8:21 AM

EPCOR USA - Stormwater Permit Renewal Information
2000 York Road, Suite 129
Oak Brook, IL 60523
Office: 630-413-5408
Mobile: [phone]
Fax: [phone]
Email: jmoorcoepcorusa.com
-----Original Message -----
From: Moore, James
Sent: Monday, December 01, 2008 3:12 PM
To: Brian Lowther
Subject: RE: Stormwater Permit Renewal Information
Brian:
Thanks for your email. I will provide you an update of
week if that is acceptable to you. I will assume that
this timeframe unless I hear differently from you.
Jim
James C. Moore
Corporate Director EHS, EPCOR USA
2000 York Road, Suite 129
Oak Brook, TT. 605?3
Office: 630-413-5408
Mobile: [phone]
Fax: [phone]
Email: [e-mail]
-----Original Message -----
From: Brian Lowther [mailto:Brian.
Sent: Monday, December 01, 2008 8:
To: Moore, James
Subject: Stormwater Permit Renewal
Jim,
[e-mail]]
25 AM
Information
our project by Thursday this
you are in agreement with
As we talked about during our phone conversation this morning, could you
send me an update of the changes occurring at the Southport and Roxboro
Sites (NCS00348 and NCS000347). Any information on the changes will be
helpful in the renewal process. I currently have some email
correspondence from April 08 that describes some of the proposed
changes. Thanks.
Brian
Brian C. Lowther
Environmental Engineer
NCDENR I DWQ I Stormwater Permitting Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
512 N. Salisbury St, Raleigh, NC 27604
Phone: [phone]
Email: [e-mail]<mailto:[e-mail]>
Website: http://h2o.enr.state.nc.us/su/3tormwater.html
3 of 4 1/26/2009 8:21 AM

EPCOR USA - Stormwater Permit Renewal Information
r Please consider the environment before printing this e-mail
NO I IGP:
This e-mail message and any attachment is intended only for the use of the individual or entity to which it is addressed and may contain
information that is privileged, confidential and exempt from disclosure under applicable law. If the reader of this message is not the intended
recipient, or the authorized employee or agent responsible for the delivery of this message to the intended recipient, you are hereby notified
that any review, retransmission, conversion to hard copy, dissemination, distribution or copying of this communication is strictly prohibited. If
you have received this communication in error, please notify me by reply and delete this message from your computer without retaining a copy
thereof. Please note that if this message is forwarded or a reply to a prior message, some or all of the attachments and other contents may not
have been produced by the sender. Thank you.
This footnote also confirms that this email message has been swept by MIMEsweeper for the presence of computer viruses.
4 of 4 1/26/2009 8:21 AM

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Coleen H. Sullins, Director
Division of Water Quality
November 10, 2008
Mr. Gary Hickey
Primary Energy of North Carolina LLC
PO Box 10836
Southpoint, NC 28461
Subject: NPDES Permit Renewal Application
Primary Energy — Southport Facility
Permit Number NCS000348
Individual Stormwater Permit
Brunswick County
Dear Mr. Hickey:
The Division of Water Quality's Stormwater Permitting Unit (SPU) acknowledges receipt of
your renewal application for coverage under NPDES Permit Number NCS000348 on October 25, 2006.
We apologize for the lengthy delay in responding to your submittal and are now making every effort'to
review your permit renewal as expeditiously as possible. Our Unit anticipates making significant
progress on individual permits over the next six months to reduce our backlog.
We are currently beginning our review of your renewal application. Please continue to comply
with all conditions and monitoring requirements in your expired NPDES stormwater permit. As
long as you have submitted a complete renewal request package and maintain compliance with those
permit conditions, stormwater discharges from this facility are authorized by that permit until the
Division issues a renewal permit or notifies you of an alternative action.
No additional information is required at this time, but we may contact you in the future. Please
notify us if any significant changes have taken place at this facility since you submitted the renewal
package. If you have any q=Stiolls about this inattei, please coulact me at [phone]
Sincerely,
2?,TZL-,
Brian C. Lowther
Environmental Engineer
Stormwater Permitting Unit
cc: Wilmington Regional Office
Stormwater Permitting Unit Files
Central Files None Carolina
,Yatuivlly
North Carolina Division of Water Quality 1617 Mail Service Center Raleigh, NC 27699-1617 Phone [phone] Customer Service
Internet: h2o.enr.state.nc.us 512 N. Salisbury St. Raleigh, NC 27604 FAX [phone]
An Equal Opportunity/Affirmative Action Employer— 50% Recycled/10% Post Consumer Paper

Lowther, Brian
From: Remington, Nikki
Sent: Friday, November 20, 2009 2:15 PM
To: Lowther, Brian
Subject: RE: Benchmarks for SC water
Hi Brian,
Sorry that it took me so long to get back to you this week. I had an agenda item I was
presenting at WQC on Wed so I haven't had a chance to look these up for you. The list below
contains the applicable saltwater benchmarks for the chemicals you requested. It always best
to use saltwater benchmarks for discharges into SC classified waters when Lhey are available.
Aluminum There is no saltwater data available on which to calculate a benchmark
Antimony There is no saltwater data available on which to calculate a benchmark
Arsenic 69 ug/L (national criteria)
Beryllium There is no saltwater data available on which to calculate a benchmark
Boron There is no saltwater data available on which to calculate a benchmark
Cadmium 40 ug/L (national criteria)
Chromium 1100 ug/L (national criteria for chromium VI)
Copper5.8 ug/L (national criteria)
Lead 220 ug/L (national criteria)
Mercury NA
Nicke175 ug/L (national criteria)
Selenium 290 ug/L (national criteria)
Silver2.2 ug/L (national criteria)
Thallium 5000 ug/L (limited data) (calculated 1/2 FAV)
Zinc 95 ug/L (national criteria)
COD The benchmark for this parameter (and TSS and 0&G) comes from somewhere
program right? I don't think that they would change for saltwater discharges
TSS ---
Sulfate There is no saltwater data available on which to calculate a benchmark
0&G ---
pH (see footnote 1) 6.8 - 8.5 (NC water quality standard)
Let me know if you have any questions
Enjoy the weekend!
Nikki
Please note new e-mail address: [e-mail]
Nikki Remington
Environmental Senior Specialist
NC Department of Environment and
and Standards Unit
1617 Mail Service Center
Raleigh NC 27699
[phone]
in your
Natural Resources Division of Water Quality -Classification
1

6t,
•duttt altlde.ttiodol (aluana S`L) OOOt°Z: t S!)Sf l otll Jo tiorltpa {ctaaa.l Isotu aql uo
umogs su saalnm Iutuuaaad Ilu of luaaufpu aa33nq palula�?aA SIluauuutaad IooJ Oi u
utulutuut Ilugs (V3SAA) IaiIlsl(t uaXV InailiaO pagsaaluM agl ut stuau3 aplJ uuoq O
•Iol aql Jo luaaaad (n)
anoJ Sjuaml uugl aaoul ou Jo aauuuipao sigl ul paugap su aNuaaAoa lol u paplimad
ag hugs `sailiAilau aanllnatAlts puu stuanJ apU uuoq uugl aaglo `satllAilan IIV g
-satlllgn puu ssaaau aoJ Sluo pasn aq hugs puu palula2aA ututuaa Bulls
aa33nq aqy •dutu atgduallodol (alnunu S-L) 000t Z:I S )Sfl aql JO uOtlzpa luaaaa
Isoul aql uo umogs sn saalnm lniuuaaad jjn of luaaufpn .IaJ3nq palnla2aA IOOJ 0f n
uiuluinut Ilugs saIIIAIIau aanllnalAlls pun suuuJ apU uuoq uugl aatllo'satlinilau IIV v
VDSA. 7' VJSAA SlaialsIG pagsaaluAAi aOJ sluamaatn ag InuoljlppV 01*6
'(UOTIMS ooiMoS oltgouzolnV Jo uoiliuiJap aaS) auTI,iluadoud
,Kuu tuouJ,SI Jo tunWTUTW u oq Ilugs sduind oqi oI solilpouJ Azoss000n puu sdutnd IanJ uo su2 III'
scitund lams Lund suO 6"6
'a3UPUTpuO STgI UT SITATI0T?
oql uoJ pogloods omelsip ualuaug aatllo zo Aum Jo Iu5?a laauls Auu utouJ IaaJ OI Jo uuntuiuitu u :louq
Ias oq Ilutls suaJJnq puu 2uidLospuul Idooxo `SIinilou uo inn uatllo Suu uo osTpuugouauu Jo Xuldsip
`a2uuols `2uiAuud 5uipnloui s2uTplinq puu sasn Sioss000u Ilu puu s2uiplinq puu sasn Iudiouiud III'
SauTZ um JO Ig IN uuou3 S3I0u9 IaS L'6
'suauu zaJJnq uo saouds 2?UT)Imd pazTnboi utniUTUTW SUP UT poluool oq Iou IIuuS Q
"JJnIS fuiuuuld Kq panoTddu oq IiuuS
nnolJ oiJJu.zl aadoud puu ssoBo puu ssau2ui uadozd aoJ mollu IiuuS a
•oinlonzls Xuoss000u uu su pauapisuoo oq Iou IIuuS v
:smolloJ su poluln2au oq Ilugs sauigouW aalias ogeuuolnV jl-aAIzQ UipuulSaaud 9'6
SMOIZVDIJIQOW W 'S.IdHDXR `OI UDFIS

E-mail correspondence to and from this address may be subject to the North Carolina Public
Records Law and may be disclosed to third parties.
-----Original Message-----
Fr•urri: LuwLher•, Brlari[rnaillu.br-lari.luwLlrer,@rrc.derrr•.guv]
Send: Monday, November 16, 2009 10:49 AM
To: Nikki Remington
Subject: RE: Benchmarks for SC water
Nikki,
I have another stormwater permit that I am working on that the receiving stream is SC. You
gave me some benchmarks for saltwater but I have a lot of parameters for this permit. Can
you look and see which benchmarks should be adjusted. Thanks
Brian
Aluminum mg/1 0.75
Antimony mg/1 0.09
Arsenic mg/1 0.36
Beryllium mg/l 0.07
Boron mg/i N/A
Cadmium mg/1 0.001
Chromium mg/l 1
Coppermg/l 0.007
Lead mg/1 0.03
Mercury mg/l N/A
Nickel mg/1 0.26
Selenium mg/1 0.056
Silvermg/1 0.001
Thallium mg/1 N/A
Zinc mg/1 0.067
COD mg/1 120
TSS mg/l 100
Sulfate mg/l 500
0&G mg/1 30
pH (see footnote 1)
standard 6 - 91
-----Original Message -----
From: Nikki Remington[mailto:[e-mail]]
Sent: Wednesday, February 18, 2009 1:14 PM
To: Brian Lowther
Cc: Connie Brower; Sandra Moore
Subject: Re: Benchmarks for SC water
Hi Brian,
As a general rule, I would suggest using saltwater benchmarks where possible when discharging
to a SC classified water. We had provided both freshwater and saltwater benchmarks to
Bethany when she encountered this issue because the parameter she was looking at had
extremely limited data for saltwater species and the freshwater benchmark was based off of a
larger data set and would have been protective of saltwater species as well based on the
c.alc.ulaLed values. I'rrr noL sure which urre she ended up using irr her• permit.. However•, lir
your case we have relatively strong data for metals in both freshwater and saltwater. I
recommend using the following saltwater benchmarks:
z

vi
CD
ig
r.

Iron: 4.5 mg/L (limited data)
Chromium: 1 mg/L
Xylene: 3.7 mg/L
Zinc: 95 ug/L
Aluminum: No saltwater data is available for aluminum
Lead: 220 ug/L
From looking at your benchmark document, it looks like oil and grease, COD, TSS and N and P
wouldn't need to be modified for saltwater. We wouldn't have any additional numeric
benchmarks available for any of these parameters besides what you already are using. I hope
this helps. Feel free to let me know if you need anything further or have any questions.
Nikki
Brian Lowther wrote:
> Nikki,
> I am working on an individual stormwater permit for a Marine Terminal
> that the receiving water is Cape Fear River and is classified as SC.
> My draft parameters for monitoring include Oil & Grease, COD, TSS, N,
> P, Fe, Cr, Xylene, Zn, Al and Pb. How will the fact that the
> receiving water is SC affect the benchmarks for the permit? Should
> they be different than if they were freshwater? Let me know what you
> think. I know Bethany dealt with this some issue in the permit for
> PCS Phosphate Aurora NCS000520 but the parameters were a little
> different.
> Brian
Nikki Remington
Environmental Senior Specialist
NC Department of Environment and
and Standards Unit
1617 Mail Service Center
Raleigh NC 27699
[phone]
Natural Resources Division of Water Quality -Classification
E-mail correspondence to and from this address may be subject to the North Carolina Public
Records Law and may be disclosed to third parties.
3

comic`
o
©
c
cyr
b
r
i7
fD
C
co
e
a�i
�n
oa
N
to
Icj
tQ
'
cz,
V
KJ
ICJ
L^
fD
CX.
s
id
N
is
cc
Ln
CA
Q
79
Cs

SO/V UL PeSIAGJ Ise] sona-az-nms
1 40 !. 969c 1
0089-L08 (61.6)""""' GOWO lea}u90
0009-4LL (962) """ uaales-uo}sulM
91•2;L-96L (0 W) —
80140 uoI6uluallM
Wf,9-9�B (393)...
90140 u016ulyseM
OOF-V-I.6L (6[6) ........
a0iJJ0 y6laluH
669 �-099 (tOL) "'
a0IJJ0 all!nsaaoOW
0069-88tr (0 W)
a01dd0 alllAelleb:e
0096-963 (8Z9) ...."
aolJl0 alLnaysy
:uoltewaoJul JaeJuoO 8011101eu01 as OMO
•easeanon ioj oolljp leuolfiay bMQ eNj;oeauoo aseeld °suotisenb roj
TOW OOOOZOJON

FOR AGENCY USE ONLY
Date Received
Division of Water Quality /Surface Water Protection yea,. :Month Da}•
NCDENRNational Pollutant Discharae Elimination SystemN: 'C m -:-7�v
` oN.UK"`RtsxNct REPRESENTATIVE OUTFALL STATUS (ROS)
REQUEST FORM
If a facility is required to sample multiple discharge locations with very similar stormwater discharges, the
permittee may petition the Director for Representative Outfall Status (ROS). DWQ may grant Representative
Outfall Status if stormwater discharges from a single outfall are representative of discharges from multiple
outfalls. Approved ROS will reduce the number of outfalls where analytical sampling requirements apply.
If Representative Outfall Status is granted, ALL outfalls are still subject to the qualitative ► olliturir►y
requirements of the facility's permit —unless otherwise allowed by the permit (such as NCG020000) and DWQ
approval. The approval letter from DWQ must be kept on site with the facility's Storm water Pollution
Prevention Plan. The facility must notify DWQ in writing if any changes affect representative status.
For questions, please contact the DWQ Regional Office for your area (see page 3).
(Please print or type)
1) Enter the permit number to which this ROS request applies:
Individual Permit (or) Certificate of Coverage
G N C G
2) Facility information:
31
Owner/Facility Name JdirH�'cr
Facility Contact L �. /,/ C 17 e /�)-. 4 f— '
Street Address Z2 S / A.- 1-4,t � Z)
City _',<Yf State Ai C ZIP Code k __
County �1u�isa,�,`t E-mail Address %>y.��?C'k / �vyC✓-t�'+y►
Telephone No. tic' qS 1 Fax: 9 1v
List the representative nutfalllsl infnrmntinn /attarh add"+innal sheets if necessary':
Outfall(s) 6' c; .3 is representative of Outfall(s)
Or, /
Outfalls' drainage areas have the same or similar activities e
24es
No
Outfalls' drainage areas contain the same or similar materials?
Lames
❑ No
Outfalls have similar monitoring results?
❑ Yes
❑ No o fro data*
Outfall(s) o `�, Gt�� is representative of Outfall(s)
coo
Outfalls' drainage areas have the same or similar activities?
dyes
❑ No
Outfalls' drainage areas contain the same or similar materials?
dyes
❑ No
Outfalls have similar monitoring results?
❑ Yes
❑ No o,No data*
Outfall(s) '� J C�1 '� is representative of Outfall(s)
C/
Outfalls' drainage areas have the same or similar activities?
&-Yes
❑ No
Outfalls' drainage areas contain the same or similar materials?
P-Yes
❑ No
Outfalls have similar monitoring results?
❑ Yes
❑ No "o data*
*Non-compliance with analytical monitoring prior to this request may prevent ROS approval. Specific
circumstances will be considered by the Regional Office responsible for review.
Page 1 of 3
SWU-ROS-2009 Last revised 12/30/2009

Representative Outfall Status Request
4) Detailed explanation about why the outfalls above should be granted Representative Status:
(Or, attach a letter or narrative to discuss this information.) For example, describe how activities and/or
materials are similar.
5) Certification:
North Carolina General Statute 143-215.6 B(i) provides that:
Any person who knowingly makes any false statement, representation, or certification in any application, record,
report, plan, or other document filed or required to be maintained under this Article or a rule implementing this
Article; or who knowingly makes a false statement of a material fact in a rulemaking proceeding or contested case
under this Article; or who falsifies, tampers with, or knowingly renders inaccurate any recording or monitoring device
or method required to be operated or maintained under this Article or rules of the [Environmental Management]
Commission implementing this Article shall be guilty of a Class 2 misdemeanor which may include a fine not to exceed
ten thousand dollars ($10,000).
I hereby request Representative Outfall Status for my NPDES Permit. I understand that ALL outfalls are still
subject to the qualitative monitoring requirements of the permit, unless otherwise allowed by the permit
and regional office approval. I must notify DWQ in writing if any changes to the facility or its operations
take place after ROS is granted that may affect this status. If ROS no longer applies, I understand I must
resume monitoring of all outfalls as specified in my NPDES permit.
I certify that I am familiar with the information contained in this application and that to the best of my
knowledge and belief such information is true, complete, and accurate.
Printed Name of Pew SigningL 1"CM4( S' ::5Z"-C- 11144 r,646V
(Signature of
///91/C
Date Signed)
Please note: This application for Representative Outfall Status is subject to approval by the
NCDENR Regional Office. The Regional Office may inspect your facility for compliance with the
conditions of the permit prior to that approval.
Final Checklist for ROS Request
This application should include the following items:
❑ This completed form.
❑ Letter or narrative elaborating on the reasons why specified outfalls should be granted representative
status, unless all information can be included in Question 4.
n Two (2) copies of a site map of the facility with the location of all autfalls clearly inai ked, i1WILHIliig the
drainage areas, industrial activities, and raw materials/finished products within each drainage area.
❑ Summary of results from monitoring conducted at the Outfalls listed in Question 3.
❑ Any other supporting documentation.
Page 2 of 3
SWU-ROS-2009 Last revised 12/30/2009

Representative Outfall Status Request
Mail the entire package to:
NC DENR Division of Water Quality
Surface Water Protection Section
at the appropriate Regional Office (See map and addresses below)
Notes
The submission of this document does not guarantee Representative Outfall Status (ROS) will be granted as
requested. Analytical monitoring as per your current permit must be continued, at all outfalls, until written
approval of this request is granted by DWQ. Non-compliance with analytical monitoring prior to this request
may prevent ROS approval. Specific circumstances will be considered by the Regional Office responsible for
review.
For questions, please contact the DWQ Regional Office for your area.
Asnevuie Kegional Office
2090 U.S. Highway 70
Swannanoa, NC 28778
Washington Regional Office
943 Washington Square Mall
Phone [phone]
Washington, NC 27889
FAX [phone]
Phone [phone]
Fayetteville Regional Office
FAX [phone] R
Systel Building,
225 Groon St., Suite 714
Wilmington Regional Office
Fayetteville, NC 28301-5094
127 Cardinal Drive Extension
Wilmington, NC 28405
Phone [phone]
FAX [phone]
Phone [phone]
FAX [phone]
Mooresville Regional Office
610 East Center Ave.
Winston-Salem Regional Office
Mooresville, NC 28115
585 Waughtown Street
Winston-Salem, NC 27107
Phone [phone]
Phone [phone]
FAX [phone]
Water Quality Main FAX [phone]
Raleigh Regional Office
Central Office
1628 Mail Service Center
1617 Mail Service Center
Raleigh, NC 27699-1628
Raleigh, NC 27699-1617
Phone [phone]
Phone [phone]
FAX [phone]
FAX [phone]
Page 3of3
SWU-ROS-2009 Last revised 12/30/2009

o
1.g
0) Cl)
ai
TL
9
W 4
A A
Ill
IA 4
A)rnti2
1
o
o
0 0 0 0
o o
o o
o o
0 0
0 0
'2 o o
N o o
0 0 0 o
0
N o
0
0
A
2�
0
0
o v
D
<
m Ln
11

Beverly Eaves Perdue
Governor
DATE: March 17, 2010
TO: Wilmington Star News
EMAIL: [e-mail]
FROM: SARAH YOUNG, DIVISION OF WATER QUALITY
SUBJECT: PUBLIC NOTICE
PAGES: 1
Please publish only the information (Public Notice) below, ONE TIME in the legal section of your paper by
Tuesday, March 16, 2010. Please fax a copy of the proof to me at [phone] for final approval prior to
publication. Within 10 days after publish date, please send the invoice and two copies of the original affidavit
to:
Sarah Young
NCDENR/DWQ Stormwater Permitting Unit
1617 Mail Service Center
Raleigh, NC 27699-1617
NC DIVISION OF WATER QUALITY INTENT TO ISSUE A STORMWATER DISCHARGE PERMIT
Public comment or objection to the draft permits is invited. Submit written comments to DWQ at the address below.
All comments received prior to April 15, 2010 will be considered in the final determination regarding permit issuance
and permit provisions.
Application: Elementis Chromium, L.P., 329 Wyckoffs Mill Roads, Hightstown, NJ 08520 has applied for an NPDES
permit to discharge stormwater from an industrial facility at: Elementis Chromium, L.P, 5408 Holly Shelter Road,
Castle Hayne NC, New Hanover County. The facility discharges to North East Cape Fear River.
Application: Capital Power Operations (USA) Inc., 110 box '10836 Southport, NC 28461 has applied for an NI'ULE
permit to discharge stormwater from an industrial facility at: Capital Power Corporation, 1281 Powerhouse Drive
Southport, NC, Brunswick County. The facility discharges to Price Creek.
Copies of draft permits, NCS000003 and NCS000348, are available at:
http://portal.ncdenr.org/web/wq/ws/su/current-notices . Additional permit documents are available for the
reproduction cost at:
DWQ Stormwater Permitting Unit
512 N. Salisbury Street (location, zip 27604)
1617 Mail Service Center (mail)
Raleigh, NC 27699-1617
DWQ Contact: Brian Lowther
(919)-807-6368
[e-mail]
Wetlands and Stormwater Branch
1617 Mail Service Center, Raleigh, North Carolina 27699-1617
Location: 512 N. Salisbury St. Raleigh, North Carolina 27604
Phone: [phone] \ FAX: [phone] \ Customer Service: 1-877-623-6748
Internet: www.ncwaterquality.org
An Equal Opportunity \ Affirmative Action Employer
Nor thCarolina
Naturai

Star -News
445�'vttAP,Cti 11 r
1003 South 17th Street • P.O. Box 840 + Wilmington, NC 28402-0840
Obits ph: 910-343-2004 or 343-2356 Obits fax: [phone] • Classified ph: 910-343-2323 Classified fax: [phone]
Order: W002387184
Pubs:
115
Rate:
L9
Phone: [phone]
Class:
0001
Charges:
$ 0.00
Account: N7335083
Start
03/15/2010
List Price:
$ 151.32
Name. Candelaria,
Stop
03/15/2010
Pay-
$ 0.00
Caller: Sarah
Inser-
Columns:
2
Balance:
$ 151.32
Taken By: 43
1
Lines:
56
Schedule: 3/15 1x, 3/15 lx, , ,
Taken On:
03/11/2010
TENT TO ISSUE A STORMWATER DIS-
CHARGE PERMIT
Public comment or objection to the draft
permits is invited. Submit written comments
to DWQ at the address below. All comments
received prior to April 15, 2010 will be con-
sidered in the final determination regarding
permit issuance and permit provisions.
Application: Elementis Chromium, L.P., 329
Wyckoffs Mill Roads, Hightstown, NJ 08520
has applied for an NPDES permit to dis-
charge stormwater from an industrial facility
at: Elementis Chromium, L.P, 5408 Holly
Shelter Road, Castle Hayne NC, New
Hanover County. The facility discharges to
North East Cape Fear River.
Application: Capital Power Operations
(USA) Inc., PO Box 10836 Southport, NC
28461 has applied for an NPDES permit to
discharge stormwater from an industrial fa-
cility at: Capital Power Corporation, 1281
Powerhouse Drive Southport, NC, Bruns-
wick County. The facility discharges to
Price Creek.
Copies of draft permits, NCS000003 and
NCS000348, are available at:
http!/portal.ncdenr.org/weblwq/ws/su/
current -notices
Additional permit documents are available
for the reproduction cost at:
DWQ Stormwater Permitting Unit
512 N. Salisbury Street (location, zip
27604), 1617 Mail Service Center (mail),
Raleigh, NC 27699-1617
DWQ Contact: Brian Lowther
(919)-807-6368
[e-mail]
Attention: Fax:
This is a final proof. If any information is incorrect, please contact your sales representative prior to the deadline of the first in-
sertion. Otherwise your order is accepted as having been approved,

AFFIDAVIT OF PUBLICATION
STATE OF NORTH CAROLINA
COUNTY OF NEW HANOVER
Before the undersigned, a Notary Public of Said County and State,
Keith Raffone
Who, being duly sworn or affirmed, according to the law, says that he/she is
Controller
of THE STAR -NEWS, a corporation organized and doing business under the Laws of the State of
North Carolina, and publishing a newspaper known as STAR -NEWS in the City of Wilmington
NC DIVISION OF WATER QUALITYINTENT TO ISSUE STORMWATER DISCHARGE
PERMIT Public comment or objection to the draft permits is invited. Submit written comments
to DWQ at the address below. All comments received prior to April 15, 2010 will be considered i
was inserted in the aforesaid newspaper in space, and on dates as follows:
3115 Ix
And at the time of such publication Star -News was a newspaper meeting all the requirements and
qualifications prescribed by Sec. No. 1-597 G.S. of N.C.
/,/ ///� 4 Title: Controller.
Sw n or affirmed to, and subscribed before me this %�i day of
m, A.D., Z0 CC
In Testimony Whereof, I have herdunto set my hand and affixed my ofCcial�"lylth*�y and
year aforesaid. N10 0'00AM
r,TAR V
Notary Publi,
My commission expires i day of , 20_LZ *.A PUW-��
Ii
Upon reading the aforegoing affidavit with the advertisement thereto annexed it is adjudged by the Court th
publication was duly and properly made and that the summons has been duly and legally served on the defendant(s).
This day of
Clerk of Superioi Coutt
MAIL TO: