NCG050312_COMPLETE FILE - HISTORICAL_20011126

STORMWATER DIVISION CODING SHEET
NCG PERMITS
PERMIT NO.
/V
DOC TYPE
,jL HISTORICAL FILE
❑ MONITORING REPORTS
DOC DATE
❑
YYYYMMDD

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
Michael F. Easley, Governor
William G. Ross Jr., Secretary
Gregory J. Thorpe, Ph.D., Acting Director
11 /26/2001
SAM CANNADY
GREYSTONE CONCRETE PRODUCTS
PO BOX 680
HENDERSON, NC 27536
Subject
Dear Permittee:
1�•
NCDE N'".
R�_�
NORTH CAROLINA DEPARTMENT OF V
ENVIRONMENT AND NATURAL:;RESOLIR\ES
O
Q�lvo % f
NPDES Wastewater Permit CoverageI ennee✓✓w, al
Greystone Concrete Products
COC Number N _ 5��
Vance County
Your facility is currently covered for wastewater discharge under General Permit NCG500000. This permit expires
on July 31, 2002. Division of Water Quality (DWQ) staff is in the process of rewriting this permit with a
scheduled reissue in the summer of 2002. Once the permit is reissued, your facility would be eligible for continued
coverage under the reissued permit.
In order to assure your continued coverage under the general permit, you must apply to the DWQ for renewal of
your permit coverage. To make this renewal process easier, we are informing you in advance that your permit
coverage will be expiring. Enclosed you will find a general permit coverage renewal application form. This
will serve as your application for renewal of your permit coverage. The application must be completed and
returned with the required information by February 01, 2002 in order to assure continued coverage under, the
general permit. There is no renewal fee associated with this process. Your facility will be invoiced for the annual
permit fee at a later date.
Failure to request renewal within this time period may result in a civil assessment of at least $250.00. Larger
penalties may be assessed depending on the delinquency of the request. Discharge of wastewater from your facility
without coverage under a valid wastewater NPDES permit would constitute a violation of NCGS 143-215.1 and
could result in assessments of civil penalties of up to $10,000 per day.
If the subject wastewater discharge to waters of the state has been terminated, please complete the enclosed
rescission request form. Mailing instructions are listed on the bottom of the form. You will be notified when the
rescission process has been completed.
If you have any questions regarding the permit coverage renewal procedures please contact the Raleigh Regional
Office at 919-571-4700 or Delonda Alexander of the Central Office Stormwater Unit at [phone], ext. 584
Sincerely,
Bradley Bennett, Supervisor
Stormwater and General Permits Unit
cc: Central Files
Stormwater and General Permits Unit Files
Raleigh Regional Office
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Slate of North Carolina
Department of Environrt,
Health and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
Sam Cannady
Greystone Concrete Products
P.O. Box 680
Henderson, NC 27536
Dear Permittee:
July 24, 1997
Subject: Certificate of Coverage No. NCG500312
Renewal of General Permit
Greystone Concrete Products
Vance County
In accordance with your application for renewal of the subject Certificate of Coverage, the Division is forwarding
the enclosed General Permit. This renewal is valid until July 31, 2002. This permit is issued pursuant to the
requirements of North Carolina General Statute 143-215 .1 and the Memorandum of Agreement between North
Carolina and the U.S. Environmental Protection Agency dated December 6, 1983. If any parts, measurement
frequencies or sampling requirements contained in this permit are unacceptable to you, you have the right to request
an individual permit by submitting an individual permit application. Unless such demand is made, this certificate
of coverage shall be final and binding.
The Certificate of Coverage for your facility. is not transferable except after notice to the Division. Use the enclosed
Permit Name/Ownership Change form to notify the Division if you sell or otherwise transfer ownership of the
subject facility. The Division may require modification or revocation and reissuance of the Certificate of Coverage.
If your facility ceases discharge of wastewater before the expiration date of this permit, contact the Regional
Office listed below at [phone]. Once discharge from your facility has ceased, this permit may be rescinded.
This permit does not affect the legal requirements to obtain other permits which may be required by the Division of
Water Quality, the Division of Land Resources, Coastal Area Management Act or any other Federal or Local
governmental permit that may be required.
If you have any questions concerning this permit, please contact the NPDES Group at the address below.
Sincerely,
-4.
A. Preston Howard, Jr., P.E.
cc: Central Files
Raleigh Regional Office
NPDES File
Facility Assessment Unit
P.O. Box 29535, Raleigh, North Carolina 27626-0535 [phone] FAX [phone] p&[e-mail]
An Equal Opportunity Affirmative Action Employer 50% recycled / 10% post -consumer paper

WTATE OF NORTH CAROLINA*
DEPARTMENT OF ENVIRONMENT, HEALTH, AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG500000
CERTIFICATE OF COVERAGE NO. NCG500312
TO DISCHARGE NON -CONTACT COOLING WATER, COOLING TOWER AND BOILER
BLOWDOWN, CONDENSATE, EXEMPT STORMWATER, COOLING WATERS ASSOCIATED WITH
HYDROELECTRIC OPERATIONS, AND SIMILIAR WASTEWATERS UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards
and regulations promulgated and adopted by the North Carolina Environmental Management
Commission, and the Federal Water Pollution Control Act, as amended,
Greystone Concrete Products
is hereby authorized to discharge
boiler blowdown, cooling tower blowdown and other similar wastewaters
from a facility located at
Greystone Concrete Products
2100 North Garnett Street
Henderson
Vance County
to receiving waters designated as subbasin 30302 in the Tar River Basin
in accordance with the effluent limitations, monitoring requirements, and other conditions set forth
in Parts I, II, III and IV of General Permit No. NCG500000 as attached.
This certificate of coverage shall become effective August 1, 1997.
This certificate of coverage shall remain in effect for the duration of the General Permit.
Signed this day July 24, 1997.
T�
i A. Preston Howard, Jr., P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission

• #a
State of North Carolina
Department of Environment,
Health and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
A. Preston Howard, Jr., P.E., Director
Mr. Sam Cannady
Greystone Concrete Products
P.O. Box 680
Henderson, North Carolina 27536
Dear Mr. Cannady:
August 23,1996
�§
Sep
Subject: General Perm �/G500000
Greystone Concrete �r-acts
Certificate of Coverage NC`C501
Vance County
In accordance with your application for discharge permit received on November 6, 1995 we are
forwarding herewith the subject certificate of coverage to discharge under the subject state - NPDES general
permit. This permit is issued pursuant to the requirements of North Carolina General Statute 143-215.1 and the
Memorandum of Agreement between North Carolina and the US Environmental Protection agency dated
December 6, 1983.
If any parts, measurement frequencies or sampling requirements contained in this permit are
unacceptable to you, you have the right to request an individual permit by submitting an individual permit
application. Unless such demand is made, this certificate of coverage shall be final and binding.
Please take notice that this certificate of coverage is not transferable except after notice to the
Division of Environmental Management. The Division of Environmental Management may require modification
or revocation and reissuance of the certificate of coverage.
This permit does not affect the legal requirements to obtain other permits which may be required by the
Division of Environmental Management or permits required by the Division of Land Resources, Coastal Area
Management Act or any other Federal or Local governmental permit that may be required.
If you have any questions concerning this permit, please contact Mack Wiggins at telephone number
[phone], extension 542.
Sincerely,
original Signed 13y
David X Goodrich
A. Preston Howard, Jr., P. E.
cc: Central Files
Raleigh Regional Officer
Permits and Engineering Unit
Facility Assessment Unit
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled / 10% post -consumer paper

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT, HEALTH, AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
TO DISCHARGE NON -CONTACT COOLING WATER, COOLING TOWER AND BOILER BLOWDOWN,
CONDENSATE AND SIMILAR WASTEWATERS UNDER THE
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act, as amended,
Greystone Concrete Products
is hereby authorized to construct and operate or continue operation of a treatment system for the generation of non -
contact cooling waters, boiler water blowdown or similar waste streams with the discharge of treated wastewater from
a facility located at
Greystone Concrete Products
on US Highway 1 North
North Henderson
Vance County
to receiving waters designated as an unnammed tributary to Fox Reservoir in the Tar -Pamlico River Basin
in accordance with the effluent limitations, monitoring requirements, and other conditions set forth in Parts I,11, III
and IV of General Permit No. NCG500000 as attached
This certificate of coverage shall become effective August 23, 1996
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day August 23, 1996
Original Signed By
David A. Goodrich
A. Preston Howard, Jr., P.E.,Director
Division of Water Quality
By Authority of the Environmental Management Commission

ROAD CLASSIFICATION
PRIMARY HIGHWAY LIGKT-DUTY ROAD, HARD OR
I& HARD SURFACE IMPROVED SURFACE
SECONDARY HIGHWAY
HARD SURFACE UNIMPROVED ROAD
Latitude* 36020'45" Longitudes Z8023-18"
Map # B25SW Sub -basin 03-03-02
Stream Class C NSW
Discharge Cooling / Boiler Blowdown
Receiving Stream UT to Fox Reservoir
Permit exp. 07/31/97 Ow 30 GPD
SCALE 1:24 000
CONTOUR INTERVAL 40 FEET
QUAD LOCATION
Greystone Concrete products
NCG500312
1p Vance County