NCG050060_COMPLETE FILE - HISTORICAL_20111118 (2)

STORMWATER DIVISION CODING SHEET
NCG PERMITS
PERMIT NO.
/v C.,& 6Q
DOCTYPE
LNk HISTORICAL FILE
❑ MONITORING REPORTS
DOC DATE
❑A o I I I n
YYYYM M DD

i
NCDENR
North Carolina Department of Environment and Natural
Division of Water Quality
Beverly Eaves Perdue
Governor
Mr. Travis Johnson
Carolina Color Corporation
Post Office Box 486
Salisbury, North Carolina 28145
Subject
Dear Mr. Johnson:
- Coleen H. Sullins
Director
November 18, 2011
FILE
Resources
Compliance Evaluation Inspection
Carolina Color Corporation
Certificate of Coverage No. NCG050060
Rowan County, NC'
Dee Freeman
Secretary
Enclosed is a copy of the Compliance Evaluation Inspection report for the inspection conducted
at the subject facility on November 9, 2011, by Mr. Michael L. Parker with this Office. Mr. Terry
Petruelli represented Carolina Color Corporation during the inspection.
The enclosed report should be self-explanatory. It was brought to Mr. Petrucelli's attention
during the inspection, that there are specific sections of your Stormwater Pollution Prevention Plan
(SPPP) that need to be addressed and/or updated. These areas were discussed with Mr. Petrucelli during
the inspection and are also noted in the Summary Section in the attached inspection report. As a
reminder, please note that your SPPP should be updated on an annual basis as required by Part 11,
Section A, No. 7 of your permit.
If you have any questions, comments, or need assistance with understanding any aspect of your
permit, please do not hesitate to contact Mr. Parker at [phone].
Sincerely,
—(I C-rc>�'
Robert B. Krebs
Regional Supervisor
Surface Water Protection Section
Enclosure
cc: Shelton Sullivan — NPS/ACO Unit
Mooresville Regional Office
Location: 610 East Center Avenue, Suite 301, Mooresville, NC 28115 One
Phone: [phone] Fax: [phone] Customer Service: 1-877-623-6748 NorthCarolina
Internet http:/Iponal.ncdenr.org/webfwq
An Equal Opportunity t Affirmative Action Employer - 50% Recycled/1 0% Post Consumer paper ✓ ' aftZrallY

Compliance Inspection Report
Permit: NCG050060 Effective: 06/01/08 Expiration: 05/31/13 Owner: Carolina Color Corporation
SOC: Effective: Expiration: Facility:'Carolina Color Corporation
County: Rowan 100 E 17th St
Region: Mooresville
Salisbury NC 28145
Contact Person: Michael Hollingsworth Title: Phone: [phone]
Directions to Facility:
System Classifications:
Primary ORC:
Secondary ORC(s):
On -Site Representative(s):
24 hour contact name
On -site representative
Related Permits:
Travis Johnson
Terry Petrucelli
Inspection Date: 11/09/2011 Entry Time: 09:00 AM
Primary Inspector: Michael L Parker
Secondary Inspector(s):
Certification: Phone:
Exit Time: 10:35 AM
Phone:
Phone:
Phone: [phone]
Ext2194
Reason for Inspection: Routine Inspection Type: Compliance Evaluation
Permit Inspection Type: AppareVPrinting/Paper/Leather/Rubber Stormwater
Discharge COC
Facility Status: ■ Compliant 0 Not Compliant
Question Areas:
E Storm Water
(See attachment summary)
Page: 1

Permit: NCG050060 Owner - Facility: Carolina Color Corporation
Inspection Date: 11 /09/2011 Inspection Type: Compliance Evaluation Reason for Visit: Routine
inspection Summary:
The existing SPPP was well organized, however, there were sections of the SPPP that were out-of-date. These sections
include:
Part I, Section A, No. 1(b): Need to provide more detail as to the narrative description of practices, especially dust or
particulate generating or control processes and waste disposal practices.
Part I, Section A, No. 1(d): Need to include in the SPPP a sheet where the person responsible for the SPPP indicates
whether or not there have been any significant spills during the three previous years. This sheet can be updated at the
time of the annual SPPP plan update.
Part I; Section A, No. 2(a): The SPPP should include a section where the technical and economic feasibility of changing
the methods of operation to eliminate or reduce exposure is evaluated.
Part I, Section A, No. 3: The SPPP should list current members of the Spill Prevention and Response Plan (SPRP) and
update this section as needed.
Part I, Section A, No. 4: Documentation of inspections and maintenance activities of material handling areas and regular
cleaning schedules of these areas should be included in the SPPP.
Part I, Section A, No. 5: Employee training should be documented in the SPPP and the person responsible for
conducting this training identified.
Part I, Section A, No. 6: The person responsible for the implementation of the SPPP should be identified.
Part I, Section A, No. 7: The SPPP should be updated annually and recertified that the stormwater outfalls do not contain
any non-stormwater discharges.
Although analytical monitoring is not required at this facility (no on -site vehicle maintenance), qualitative monitoring, as
required by the SPPP should be conducted at all outfalls and this information included in the SPPP.
Based on observations made during the site visit, it may be possible for this facility to obtain No -Exposure coverage,
which would eliminate the need for a SW permit. Further evaluation and eventual removal of any areas of exposure may
allow the Division to consider this facility as a No -exposure candidate. A regulatory definition of No -exposure can be
found on the Division's web site.
Page: 2

A
Permit: NCGO50060 Owner - Facility: Carolina Color Corporation
Inspection Date: 11109/2011 Inspection Type: Compliance Evaluation Reason for Visit: Routine
Stormwater Pollution Prevention Plan Yes No NA NE
Does the site have a Stormwater Pollution Prevention Plan?
■ ❑ ❑
❑
# Does the Plan include a General Location (USGS) map?
■ n n
Cl
# Does the Plan include a "Narrative Description of Practices"?
■ n n
n
# Does the Plan include a detailed site map including outfall locations and drainage areas?
■ ❑ fl
❑
# Does the Plan include a list of significant spills occurring during the past 3 years?
■ n n
n
# Has the facility evaluated feasible alternatives to current practices?
■ ❑ ❑
Q
# Does the facility provide all necessary secondary containment?
❑ Q ■
❑
# Does the Plan include a BMP summary?
❑ Q ■
❑
# Does the Plan include a Spill Prevention and Response Plan (SPRP)?
■ n n
❑
# Does the Plan include a Preventative Maintenance and Good Housekeeping Plan?
■ ❑ rl
❑
# Does the facility provide and document Employee Training?
■ ❑ n
n
# Does the Plan include a list of Responsible Party(s)?
■ 0 ❑
❑
# Is the Plan reviewed and updated annually?
n ■ ❑
n
# Does the Plan include a Stormwater Facility Inspection Program?
n n ■
n
Has the Stormwater Pollution Prevention Plan been implemented?
■ ❑ ❑
❑
Comment: There are a number of areas of the SPPP that need to be updated (see
Summary)
Qualitative Monitoring Yes No .NA NE
Has the facility conducted its Qualitative Monitoring semi-annually? ❑ ■ ❑ ❑
Comment: Qualitative monitoring needs to be conducted in accordance with the
permit requirements.
Permit and Outfalls Yes No NA NE
# Is a copy of the Permit and the Certificate of Coverage available at the site? ■ ❑ ❑ [l
# Were all outfalls observed during the inspection? ■ ❑ ❑ ❑
# If the facility has representative outfall status, is it properly documented by the Division? Q 0 ■ 0
# Has the facility evaluated all illicit (non stormwater) discharges? ■ l=l Q Q
Comment: There was only one stormwater outfall that drained the industrial process
area of the plant.
Page: 3

FILE
Affl;-Ak
NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue
Govemor
Mr. Michael Hollingsworth
Carolina Color Corporation
100 East 17`h Street
Salisbury, NC 28145
Dear Mr. Hollingsworth:
Coleen H. Sullins
Director
November 1, 2011
Subject: General Stormwater Permit
Carolina Color Corporation
COC No. NCG050060
Rowan County
Dee Freeman
Secretary
Our records indicate that you have been issued the subject Certificate of Coverage (COC) under NPDES
General Permit (GP) No. NCG03000 from the North Carolina Division of Water Quality to discharge stormwater
associated with industrial activities performed at your facility. The purpose of this letter is to advise you that an
inspection is planned at your facility on November 9, 2011 at 11:00 am to ascertain compliance with the
aforementioned GP. If this date and/or time are not convenient for you or there is someone else with your company
that will be available to accompany me during my visit, you can contact me via email at
Michael.Parker 4,ncdenr.gov or at my phone number listed below to confirm your participation or to reschedule this
visit
During the course of this inspection, you should be prepared to demonstrate your facility's compliance with
all terms and conditions as set forth in the GP. The following areas (if applicable) of the GP will be evaluated
during the inspection: Stormwater Pollution Prevention Plan, stormwater outfall locations, qualitative and/or
analytical monitoring data, and Representative Outfall status (if applicable).
If you are no longer the contact person for this facility, please provide this Office with the name of the
current contact person and a phone number where they can be reached so we can update our records. If you have
any questions regarding this matter, I can be contacted at [phone].
Sincerely,;
Michael L. Parker
Environmental Engineer II
Surface Water Protection
Mooresville Regional Office
Location: 610 East Center Avenue. Suite 301, Mooresville, NC 28115
Phone: [phone] Fax: [phone] Customer Service: 1-877-623-6748
Internet: httpd/portal.ncdenr.Mtweb/wq
An Equal Opportunity 1 Affirmative Action Employer - 50 Recyciedlt 0% Post Consumer paper
NorthCarol.i na
NritlCtally

A

1+7li hael`F� Easley; �overa©r ICE
Williamr G_ Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan el� P„EZWtty
n d� t li
September 4, 2002
GEORGE J TRAPP
CAROLINA COLOR CORPORATION
PO BOX 486 100 EAST 17TH
SALISBURY. NC 28145
Subject: NPDES Stormwater Permit Coverage Renewal
Carolina Color Corporation
COC Number NCGO50060
Rowan County
Dear Permittee:
Your facility is currently covered for stormwater discharge under General Permit NCG050000. This permit expires
on March 31, 2003. The Division staff is currently in the process of rewriting this permit and is scheduled to have
the permit reissued by early spring of 2003. Once the permit is reissued, your facility would be eligible for
continued coverage under the reissued permit.
In order to assure your continued coverage under the general permit, you must apply to the Division of Water
Quality (DWQ) for renewal of your permit coverage. To make this renewal process easier. we are informing you in
advance that your permit coverage will be expiring. Enclosed you will find a Permit Coverage Renewal
Application Form. The application must be completed and returned by October 2. 2002 in order to assure
continued coverage under the general permit. Due to staff and budget constraints, letters confirming our receipt of
the completed application will not be sent.
Failure to request renewal within the time period specified, may result in a civil assessment of at least $250.00.
Larger penalties may he assessed depending on the delinquency of the request. Discharge of stormwater from your
facility without coverage under a valid stormwater NPDES permit would constitute a violation of NCGS 143-21.5.1
and could result in assessments of civil penalties of up to $10.000 per day.
Please note that recent federal legislation has extended the "no exposure exclusion" to all operators of industrial
Facilities in any of the I I categories of "storm water discharges associated with industrial activity," (except
construction activities). If you feel your facility can certify a condition of "no exposure". i.e. the facility industrial
materials and operations are not exposed to stormwater, you can apply for the no exposure exclusion. For additional
information contact the Central Office Stormwater Staff member listed below or check the Stormwater & General
Permits Unit Web Site at http://h2o.enr.state.nc.us/su/stormwater.html
If the subject stormwater discharge to waters of the state has been terminated, please complete the enclosed
Rescission Request Form. Mailing instructions are listed on the bottom of the form. You will be notified when the
rescission process has been completed.
If you have any questions reYgarding the permit renewal procedures please contact Mike Parker of the Mooresville
Regional Office at 704-663-1699 or Aisha Lau of the Central Office Stormwater Unit at [phone], ext_ 578
Sincerely.
Bradley Bennett. Supervisor
Stormwater and General Permits Unit
cc: Central Files
Stormwater and General Permits Unit Files
Mooresville Regional Office ©��
WDENR
N. C. Division of Water Ouality 1617 Mail Service Center Raleigh, NC 27699-1617 [phone] Customer Service
1- 800-623-7748

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
Michael F. Easley, Governor
William G. Ross Jr., Secretary
Alan W. Klimek, P.E. Director
10/24/2002
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
CAROLINA COLOR CORPORATION
PO BOX 486 100 EAST 17TH
SALISBURY, NC 28145
e��
NCDI.
- 1T,IIRONL1ENT
} ��SOURCES
x �� �... 1.OFFICE
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL_ RESOURCES
NOV 0 7 2002
Subject: NOTICE OF VIOLATION
FAILURE TO SUBMIT RENEWAL APPLICATION
CAROLINA COLOR CORPORATION
NCGO50000
COC NUMBER NCGO50060
ROWAN COUNTY
Dear Permittee:
This letter is to inform you that, as of the date of this letter, the Division of Water Quality has not received a
renewal request for the subject permit certificate of coverage. This is a violation of NCGS § 143.215.1 (c)(1) which
states "All applications shall be filed with the commission at least 180 days in advance of the date on which it is
desired to commence the discharge of wastes or the date on which an existing permit expires, as the case may be".
Any permittee that has not requested renewal at least 180 days prior to expiration or permittee that does not have a
permit after the expiration and has not requested renewal at least 180 days prior to expiration, will be subjected to
enforcement procedures as provided in NCGS § 143-215.6 and 33 USC 1251 et. seq.
In order to prevent continued, escalated action, including the assessment of civil penalties you must submit a
completed permit coverage renewal application to the attention of the "Stormwater and General Permits Unit" at
the letterhead address within ten (10) days of your receipt of this letter (renewal application enclosed). If the
subject discharge has been terminated, please complete the enclosed rescission request form. A valid reason for
requesting rescission is required, incomplete forms will be returned and you will still be subject to possible
escalated action. Mailing instructions for submitting rescission request are listed on the bottom of the form. You
will be notified when the rescission process has been completed.
Thank you for your prompt attention to this situation. If you have any questions regarding this matter, please
contact Aisha Lau of the central office Stormwater and General Permits Unit at 919-733-5083, ext. 578.
Sincerely,
for Alan W. Klimek, P.E.
Director, Division of Water Quality
cc: Stormwater and General Permits Unit Files
Central Files
Mooresville Regional Office
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 109/6 post -consumer paper

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG050000
CERTIFICATE OF COVERAGE No. NCGO50060
STORMWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended,
Carolina Color Corporation
is hereby authorized to discharge stormwater from a facility located at
Carolina Color Corporation
100 East 17Th St
Salisbury
Rowan County
to receiving waters designated as a UT to Grants Creek, a class C stream, in the Yadkin - Pee
Dee River Basin in accordance with the effluent limitations, monitoring requirements, and other
conditions set forth in Parts I, II, III, IV, V, and VI of General Permit No. NCG050000 as
attached.
This certificate of coverage shall become effective May 1, 2003.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day April 28, 2003.
for Alan W. Klimek, P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E. Director
Division of Water Quality
\r AC DEPT. Ut: EI-X4RONVENT
!ND NATURAL RESOURCES
April 28, 2003 `" - , ONAL OFFICE
Jeff Smink
Carolina Color Corporation APR 3 0 2003
P O Box 486
Salisbury, NC 28145
Subject: NPDES Stormwater Permit Renewal Carolina Color Corporation WATEE p n,V A 1.1TV`
COC Number NCG050060
Rowan County
Dear Permittee:
In response to your renewal application for continued coverage under general permit NCG050000, the
Division of Water Quality (DWQ) is forwarding herewith the reissued stormwater general permit. This
permit is reissued pursuant to the requirements of North Carolina General Statute 143-215.1 and the
Memorandum of Agreement between the state of North Carolina and the U.S. Environmental Protection
Agency, dated December 6, 1983.
The following information is included with your permit package:
• A new Certificate of Coverage
• A copy of General Stormwater Permit NCG050000
• A copy of the Analytical Monitoring Form (DMR)
• A copy of the Qualitativel Monitoring Form
• A copy of a Technical Bulletin for the general permit
Your coverage under this general permit is not transferable except after notice to DWQ. The Division
may require modification or revocation and reissuance of the Certificate of Coverage. This permit does
not affect the legal requirements to obtain other permits which may be required by the Department of
Environment and Natural Resources, or relieve the permittee from responsibility for compliance with any
other applicable federal, state, or local law, rule, standard, ordinance, order, judgment, or decree.
If you have any questions regarding this permit package please contact Aisha Lau of the Central Office
Stormwater and General Permits Unit at [phone], ext. 578.
Sincerely,
Bradley Bennett, Supervisor
Stormwater and General Permits Unit
cc: Central Files
Stormwater & General Permits Unit Files
Mooresville Regional Office
N. C. Division of Water Quality 1617 Mail Service Center Raleigh, NC 27699-1617 [phone]
R
Customer Service
1 800 623-7748

WA rF
9QG
Michael F. Easley, Govemor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
`04O
—
Alan W. Klimek, P.E. Director
Division of Water Quality
� Y
April 28, 2003
Jeff Smink
Carolina Color Corporation
P O Box 486
Salisbury, NC 28145
Subject: NPDES Stormwater Permit Renewal
Carolina Color Corporation
COC Number NCGO50060
Rowan County
Dear Permittee:
In response to your renewal application for continued coverage under general permit NCG050000, the
Division of Water Quality (DWQ) is forwarding herewith the reissued stormwater general permit. This
permit is reissued pursuant to the requirements of North Carolina General Statute 143-215.1 and the
Memorandum of Agreement between the state of North Carolina and the U.S. Environmental Protection
Agency, dated December 6, 1983.
The following information is included with your permit package:
• Anew Certificate of Coverage
• A copy of General Stormwater Permit NCG050000
• A copy of the Analytical Monitoring Form (DMR)
• A copy of the Qualitativel Monitoring Form
• A copy of a Technical Bulletin for the general permit
Your coverage under this general permit is not transferable except after notice to DWQ. The Division
may require modification or revocation and reissuance of the Certificate of Coverage. This permit does
not affect the legal requirements to obtain other permits which may be required by the Department of
Environment and Natural Resources, or relieve the permittee from responsibility for compliance with any
other applicable federal, state, or local law, rule, standard, ordinance, order, judgment, or decree.
If you have any questions regarding this permit package please contact Aisha Lau of the Central Office
Stormwater and General Permits Unit at [phone], ext. 578.
Sincerely,
Bradley Bennett, Supervisor
Stormwater and General Permits Unit
cc: Central Files
Stormwater & General Permits Unit Files
Mooresville Regional Office
OWN&
N. C. Division of Water Quality 1617 Mail Service Center Raleigh, NC 27690,1617 [phone] Customer Service
1 800 623-7748

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG050000
CERTIFICATE OF COVERAGE No. NCG050060
STORMWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended,
Carolina Color Corporation
is hereby authorized to discharge stormwater from a facility located at
Carolina Color Corporation
100 East 17Th St
Salisbury
Rowan County
to receiving waters designated as a UT to Grants Creek, a class C stream, in the Yadkin - Pee
Dee River Basin in accordance with the effluent limitations, monitoring requirements, and other
conditions set forth in Parts I, II, III, IV, V, and VI of General Permit No. NCGO50000 as
attached.
This certificate of coverage shall become effective May 1, 2003.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day April 28, 2003.
for Alan W. Klimek, P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
Michael F. Easley, Governor
William G. Ross Jr., Secretary
Alan W. Klimek, P.E. Director
10/24/2002
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
CAROLINA COLOR CORPORATION
PO BOX 486 100 EAST 17TH
SALISBURY, NC 28145
A410
-- =a
IL
NCDENR
NORTH CaRoLiNA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: NOTICE OF VIOLATION
FAILURE TO SUBMIT RENEWAL APPLICATION
CAROLINA COLOR CORPORATION
NCG050000
COC NUMBER NCG050060
ROWAN COUNTY
Dear Permittee:
This letter is to inform you that, as of the date of this letter, the Division of Water Quality has not received a
renewal request for the subject permit certificate of coverage. This is a violation of NCGS §143.215.1 (c)(1) which
states "All applications shall be filed with the commission at least 180 days in advance of the date on which it is
desired to commence the discharge of wastes or the date on which an existing permit expires, as the case may be".
Any permittee that has not requested renewal at least 180 days prior to expiration or permittee that does not have a
permit after the expiration and has not requested renewal at least 180 days prior to expiration, will be subjected to
enforcement procedures as provided in NCGS § 143-215.6 and 33 USC 1251 et. seq.
In order to prevent continued, escalated action, including the assessment of civil penalties you must submit a
completed permit coverage renewal application to the attention of the "Stormwater and General Permits Unit" at
the letterhead address within ten (10) days of your receipt of this letter (renewal application enclosed). If the
subject discharge has been terminated, please complete the enclosed rescission request form. A valid reason for
requesting rescission is required, incomplete forms will be returned and you will still be subject to possible
escalated action. Mailing instructions for submitting rescission request are listed on the bottom of the form. You
will be notified when the rescission process has been completed.
Thank you for your prompt attention to this situation. If you have any questions regarding this matter, please
contact Aisha Lau of the central office Stormwater and General Permits Unit at 919-733-5083, ext. 578.
Sincerely,
for Alan W. Klimek, P.E.
Director, Division of Water Quality
cc: Y Stormwater and General Permits Unit Files
Central Files
Mooresville Regional Office
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 500% recycled/ 10% post -consumer paper

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
April 30, 1998
DENNIS R WHITE
CAROLINA COLOR CORPORATION
PO BOX 486 100 EAST 17TH ST
SALISBURY, NC 28145
Subject: Reissued Stormwater General Permit for Certificate of Coverage No. NCGO50060
Rowan County
Dear Permittee:
In response to your renewal application for continued coverage under the subject permit, the Division
of Water Quality (DWQ) is forwarding herewith the reissued stormwater general permit. This permit
is reissued pursuant to the requirements of North Carolina General Statute 143-215.1 and the
Memorandum of Agreement between North Carolina and the US Environmental Protection agency
dated December 6, 1983.
The following information is included with your permit package:
n A copy of the stormwater general permit.
■ A Stormwater Pollution Prevention Plan Certification Form. This form certifies that you have
developed and implemented the Stormwater Pollution Prevention Plan (SPPP) required in your
permit. This form must be completed and returned to the Division within 30 days of receipt of
this letter. DO NOT send the SPPP with the signed form.
■ Five copies of Analytical Monitoring forms.
■ Five copies of Qualitative Monitoring forms.
■ A copy of a Technical Bulletin on the stormwater program which outlines program components
and addresses frequently asked questions.
■ A corrected Certificate of Coverage if you indicated a name or address change on the Renewal
Form returned to the Division.
Your certificate of coverage is not transferable except after notice to DWQ. The Division of Water
Quality may require modification or revocation and reissuance of the certificate of coverage.
This permit does not affect the legal requirements to obtain other permits which may be required by
DWQ or permits required by the Division of Land Resources, Division of Air Quality, Coastal Area
Management Act or any other Federal or Local governmental permits that may be required.
If you have any questions concerning this permit or other attached documents, please contact the
Stormwater and General Permits Unit at telephone number [phone]
Sincerely,
V41V4761—
foA. Preston Howard, Jr., P. E.
P.O. Box 29535, Raleigh, North,Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 5017c recycled/ 10% post -consumer paper

ti
State of North Carolina
Department of Environment,
Health and Natural Resources
Division of Environmental Management
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
A. Preston Howard, Jr., P.E., Director
June 11, 1993
Dennis R. White
Carolina Color Corporation
P O Box 486
Salisbury, NC 28145
A��
E:>EHNR
Subject: General Permit No. NCG050000
Carolina Color Corporation
COC NCG050060
Rowan County
Dear Mr. White:
In accordance with your application for discharge permit received on October 1, 1992, we are
forwarding herewith the subject certificate of coverage to discharge under the subject state - NPDES general
permit. This permit is issued pursuant to the requirements of North Carolina General Statute 143-215.1 and the
Memorandum of Agreement between North Carolina and the US Environmental Protection agency dated
December 6, 1983.
If any parts, measurement frequencies or sampling requirements contained in this permit are
unacceptable to you, you have the right to request an individual permit by submitting an individual permit
application. Unless such demand is made, this certificate of coverage shall be final and binding.
Please take notice that this certificate of coverage is not transferable except after notice to the Division
of Environmental Management. The Division of Environmental Management may require modification or
revocation and reissuance of the certificate of coverage.
This permit does not affect the legal requirements to obtain other permits which may be required by the
Division of Environmental Management or permits required by the Division of Land Resources, Coastal Area
Management Act or any other Federal or Local governmental permit that may be required.
If you have any questions concerning this permit, please contact Mr. Steve Ulmer at telephone number 919n33-
5083.
cc:
Sincerely,
Original Signed By
Coleeri H. Sullins
A. Preston Howard, Jr., P. E.
Mooresville Regional Office
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 506/6 recycled/ 10% post -consumer paper

N
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT, HEALTH, AND NATURAL RESOURCES
DIVISION OF ENVIRONMENTAL MANAGEMENT
STORMWATER DISCHARGES
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act, as amended,
Carolina Color Corporation
is hereby authorized to discharge stormwater from a facility located at
Carolina Color Corporation
100 East 17th Street
Salisbury
Rowan County
to receiving waters designated as an unnamed tributary to Grants Creek in the Yadkin -Pee Dee River Basin
in accordance with the effluent limitations, monitoring requirements, and other conditions set forth in Parts I, II, III
and 1V of General Permit No. NCO050000 as attached.
This certificate of coverage shall become effective June H , 1993.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day June 11, 1993.
Original Signed By
Coleen H. Sullins
A. Preston Howard, Jr., P.E., Director
Division of Environmental Management
By Authority of the Environmental Management Commission

• r� , inn c `;•� _� r`
• _ � • •�• �_ • +ter
uftb
•
�! -� • r Carolina Color Corp.
. • • ' • :` s Salisbury, N.C.
Location Map
®a� r , • ti + _. • �, 1► (From USGS Salisbury Quad.)
m _r `+� •� o� , Scale: 1" =. 500' Date: April.'92

FACILITY
1 1410&ej 6/1'
COUNTY
'awaI
N PDES
IIc6- o 15 0060
MAP #�
Z— 0 NN✓
DSN FLOW
MA
SUB BASIN
03 -07-04-
LATTITUDE
35,-gUv7--
LONGITUDE
?o b
RECEIVING STREAM
a u00� 4u{� f� �rawf CfPek
STREAM CLASS
G
DISCHARGE CLASS
lvxmwu &
EXPIRATION DATE.
z9v3i— 17