NCG030284_COMPLETE FILE - HISTORICAL_20091002

STORMWATER DIVISION CODING SHEET
NC6 PERMITS
PERMIT NO.
IV C& 0,291
DOC TYPE
HISTORICAL FILE
❑ MONITORING REPORTS
DOC DATE
❑ c,20D % JU U off.
YYYYMMDD

.i
fu)--
SA*
���r
NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins
Govemor Director
October 2, 2009
Mr. Tom McDowell, Operations Manager
Gerdau Ameristeel Corporation
301 Black Satchel Drive
Charlotte, NC 28216
Subject: Follow-up Compliance Evaluation Inspection
Gerdau Ameristeel Corporation
301 Black Satchel Drive
Stormwater Permit Number COC NCG030284
Mecklenburg County, NC
Dear Mr. McDowell:
Dee Freeman
Secretary
Enclosed is a copy of the Follow-up Compliance Evaluation Inspection (CEI) report for the inspection conducted
at the subject facility on September 9, 2009, by Ms. Aliyah Turner of Charlotte -:Mecklenburg Storm Water
Services (CMSWS). This inspection was conducted as part of a cooperative working agreement between
Mecklenburg County and the Division of Water Quality. In addition, the inspection was conducted on behalf of
the City of Charlotte in compliance with the City's NPDES Permit, NCS000240, Part II Section H. Thank you
for your assistance and cooperation during the follow-up inspection.
The follow-up inspection found that Gerdau Ameristeel Corporation has implemented the corrective actions as
stated in the subject facility's response letter dated June 17, 2009. The corrective actions included:
Updating and implementing the Stormwater Pollution Prevention Plan in compliance with the
General permit and
Implementing Best Management Practices to prevent wastewater discharges and debris from
entering into the storm sewer system.
Should you have any questions regarding your permit, please do not hesitate to contact Ms. Allocco of this Office
at (704) 663 -1699.
Sincerely,
for Robert B. Krebs, Regional Supervisor
Surface Water Protection Section
Mooresville Regional Office
cc: NPS-ACO Unit Rusty Rozzelle, Mecklenburg County
Craig Miller, City of Charlotte
Mooresville Regional Office
Location: 610 East Center Ave., Suite 301 Mooresville, NC 28115
Phone: [phone] Fax: [phone] t Customer Service: 1-877-623-6748
Internet www.newaterquality.on3
n� c—.1 MMminity l A�rmafivP Arfinn ;:mninvar— 5ii% RCarvrJm!1n% Prat rhrn;mar narwr
One
NorthCarolina

i
Permit: NCG030284
SOC:
County: Mecklenburg
Region: Mooresville
Compliance Inspection Report
Effective: 11/01/07 Expiration: 10/31/12 Owner: Gerdau Ameristeel Corporation
Effective: Expiration: Facility: Charlotte Rebar Division
301 Black Satchel Dr
Contact Person: Scott Cox
Directions to Facility:
System Classifications:
Primary ORC:
Secondary ORC(s):
On -Site Representative(s):
Related Permits:
Charlotte NC 28216
Title: Phone: [phone]
Certification: Phone:
Inspection Date: 09109/2009 Entry Time: 01:00 PM Exit Time: 02:30 PM
Primary Inspector: Water Quality Program Meckenburg County Phone: [phone]
Secondary Inspector(s):
Reason for Inspection: Follow-up Inspection Type: Compliance Evaluation
Permit Inspection Type: Metal Fabrication Stormwater Discharge COC
Facility Status: ■ Compliant ❑ Not Compliant
Question Areas:
Storm Water
(See attachment summary)
Page: 1

4
Permit: NCG030284 Owner — Facility: Gerdau Arensteel Corporation
Inspection Date: 09/09/2009 Inspection Type: Compliance Evaluation Reason for Visit: Follow-up
Inspection Summary:
Facility Description:
The Gerdau Ameristeel facility conducts shearing and bending of reinforcing steel bar to specific lengths for the use in
concrete reinforcement construction projects. All manufacturing activities are conducted indoors and not exposed to
stormwater. The facility temporarily stores raw materials (reinforcing steel bars) and products outdoors until they are
shipped off site.
Compliance Histo :
A stormwater inspection was conducted by Ms. Aliyah Turner of Charlotte -Mecklenburg Stormwater Services
(CMSWS) on March 26, 2009. The North Carolina Division of Water Quality issued a Notice of Violation to the
permittee on April 9, 2009.
Industrial Operations/CityOperations/City of Charlotte Stormwater Ordinance Review:
Several housekeeping issues were observed during the initial stormwater inspection. The issues were as follows
Hydraulic Heat Exchanger - During the stormwater inspection, oil was observed on the ground surface at the base of
the facility's hydraulic heat exchanger_ The permittee was directed to install secondary containment that will prevent
discharges of oil onto.the ground surface.
Drums - During the inspection, two empty 55-gallon drums were observed outside of the manufacturing building.
Empty drums can contain residual fluids that can possibly contaminate stormwater. The permittee should ensure that
empty drums are not exposed to stormwater that have once contained oil and other industrial fluids. It is recommended
the facility properly dispose of empty drums_
Storm Drain Inlet - During the inspection, a storm drain inlet was observed that contained a significant amount of
gravel and dirt. According to facility personnel the facility is in the process of removing debris from the storm drain inlet.
The facility should continue to remove and prevent debris from entering into the storm drain inlet.
Old Equipment - During the inspection, abandoned industrial equipment was observed under tarp. The tarp was in bad
condition, exposing oily industrial equipment. The permittee should ensure that leaky equipment is properly covered to
prevent stormwater contamination. It is recommended that the facility use a catch pan to contain leaking oil under
equipment.
Forklift — A leaky forklift was observed on site. The permittee should prevent automotive fluids from leaking to the
ground surface by installing a pan underneath the forklift to catch fluids.
The follow-up stormwater inspection on September 9, 2009, revealed that the permittee has remediated all areas that
could contribute to stormwater contamination. The remediated items are as follows:
Hydraulic Heat Exchanger - The permittee provided documentation that the hydraulic heat exchanger was removed
from the facility on April 9, 2009, by Heritage — Crystal Clean LLC.
Drums — No drums were observed outdoors and exposed to stormwater
Storm Drain Inlet -
The permittee has placed a tarp in storm drains to keep debris from discharging into the storm sewer system. Also, the
permittee periodically removes debris from the storm drains.
Page: 2

Permit: NCG030444 Owner — Facility: {dental Equipment LLC DBA Pelton & Crane
Inspection Date: 02/12/09 Inspection Type: Compliance Evaluation Reason for Visit: Routine
Old Equipment — Old equipment was observed on a flatbed trailer and covered with a tarp to prevent stormwater
contamination.
Forklift — The permittee provided documentation that the leaky forklift had been serviced and was no longer leaking
automotive fluids.
Page: 3 .

Permit: NCGO30284 Owner - Facility: Gerdau Arrmensteel Corporation
Inspection Date: 09I09/2009 Inspection Type: compliance Evaluation Reason for Visit: Follow-up
Stormwater Pollution Prevention Plan
Yes
No
NA
NE
Does the site have a Stormwater Pollution Prevention Plan?
■
D
D
D
# Does the Plan include a General Location (USGS) map?
■
D
D
D
# Does the Plan include a "Narrative Description of Practices°?
■
n
n
D
# Does the Plan include a detailed site map including outfall locations and drainage areas?
■
D
D
D
# Does the Plan include a list of significant spills occurring during the past 3 years?
■
D
D
D
# Has the facility evaluated feasible alternatives to current practices?
■
❑
❑
D
# Does the facility provide all necessary secondary containment?
■
D
D
# Does the Plan include a BMP summary?
■
D
0
D
# Does the Plan include a Spill Prevention and Response Plan (SPRP)?
■
D
D
D
# Does the Plan include a Preventative Maintenance and Good Housekeeping Plan?
■
D
D
D
# Does the facility provide and document Employee Training?
■
D
n
D
# Does the Plan include a list of Responsible Party(s)?
■
D
D
D
# is the Plan reviewed and updated annually?
■
❑
❑
D
# Does the Plan include a Stormwater Facility Inspection Program?
■
D
D
D
Has the Stormwater Pollution Prevention Plan been implemented?
■
D
D
D .
Comment: not include the longitude & latitude coordinates of the facility's outfall. The
SPPP did not include a Feasibility Study, BMP Summary, Preventative Maintenance
and Good Housekeeping Plan, and a Spill Prevention and Response Plan (SPRP)_ The
Responsible Party section of the SPPP needs to be updated and there was no
documentation for employee training.
The follow-up stormwater inspection found that the permittee has included the
longitude & latitude coordinates of the outfalls on the USGS map. The SPPP included a
Feasibility Study, a BMP Study, a Spill Prevention and Response Plan (SPRP), a
Preventative Maintenance and Good Housekeeping Plan, and the responsible party list
has been updated in the plan. Also, the permittee included documentation of employee
training conducted on April 3, 2009, in the SPPP.
Qualitative Monitoring Yes No NA NE
Has the facility conducted its Qualitative Monitoring semi-annually? ■ D D D
Comment: The permittee did not provide documentation of qualitative monitoring
activities during the initial inspection.
During the follow-up stormwater inspection on September 9, 2009, the permittee
provided documentation of qualitative monitoring activities conducted on May 15, 2009,
Analytical Monitoring Yes No NA NE
Page: 4

Permit: NCG030284 Owner - Facility: Gerdau Ameristeel Corporation
Inspection Date: 09/09/2009 Inspection Type: Compliance Evaluation Reason for Visit: Follow-up
Has the facility conducted its Analytical monitoring? ■ n n n
# Has the facility conducted its Analytical monitoring from Vehicle Maintenance areas? fl 01 ■ 0
Comment: The permittee did not provide documentation of analytical monitoring
activities during the initial inspection.
During the follow-up stormwater inspection on September 9, 2009, the permittee
provided documentation of analytical monitoring activities conducted on May 15, 2009.
Permit and Outfalls Yes No NA NE
# Is a copy of the Permit and the Certificate of Coverage available at the site? ■ fl fl
# Were all outfalls observed during the inspection? ■ F_l n ri
# If the facility has representative outfall status, is it properly documented by the Division? fi f_'1 ■ 0
# Has the facility evaluated all illicit (non stormwater) discharges? ■ fl 0 D
Comment: The permittee provided documentation for the evaluation of stormwater
outfalls for the presence of non -stormwater discharges.
Page: 5

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E., Director
Division of Water Quality
August 23, 2002
SCOTT COX
CHARLOTTE RE13AR DIVISION
301 BLACK SATCHEL DRIVE
CHARLOTTE, NC 28216
Subject: NPDES Stormwater Permit Renewal
CHARLOTTE REBAR DIVISION
COC Number NCG030284
Mecklenburg County
Dear Permittee:
In response to your renewal application for continued coverage under general permit NCG030000, the Division of
Water Quality (DWQ) is forwarding herewith the reissued stormwater general permit. This permit is reissued
pursuant to the requirements of North Carolina General Statute 143-215.1 and the Memorandum of Agreement
between the state of North Carolina and the U.S. Environmental Protection Agency, dated December 6, 1983.
The following information is included with your permit package:
* A new Certificate of Coverage
* A copy of General Stormwater Permit NCG030000
* A copy of the Analytical Monitoring Form (DMR)
* A copy of a Technical Bulletin for the general permit
Your coverage under this general permit is not transferable except after notice to DWQ. The Division may require
modification or revocation and reissuance of the Certificate of Coverage. This permit does not affect the legal
requirements to obtain other permits which may be required by DENR or relieve the permittee from responsibility
for compliance with any other applicable federal, state, or local law, rule, standard, ordinance, order, judgment, or
decree.
If you have any questions regarding this permit package please contact Mack Wiggins of the Central Office
Stormwater and General Permits Unit at [phone], ext. 542
Sincerely,
Bradley Bennett, Supervisor
Stormwater and General Permits Unit
cc: Central Files
Stormwater & General Permits Unit Files
Mooresville Regional Office
N. C. Division of Water Quality 1617 Mail Service Center Raleigh, NC 27699-1617 [phone]
®��
NCDENR
Customer Service
1- 800-623-7748

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG030000
CERTIFICATE OF COVERAGE No. NCG030284
STORMWATER DISCHARGES
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act, as amended,
AMERISTEEL CORPORATION
is hereby authorized to discharge stormwater from a facility located at
CHARLOTTE REBAR DIVISION
301 BLACK SATCHEL DRIVE
CHARLOTTE
MECKLENBURG COUNTY
to receiving waters designated as a UT to Stewart Creek, a class C stream, in the Catawba River Basin in accordance
with the effluent limitations, monitoring requirements, and other conditions set forth in Parts 1,11, 111, IV, V, and VI
of General Permit No. N00030000 as attached.
This certificate of coverage shall become effective September 1, 2002,
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day August 23, 2002.
for Alan W. Klimek, P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
Michael F. Easley, Governor
William G. Ross Jr., Secretary
Alan W. Klimek, P.E. Director
CERTEIED MAIL
RETURN RECEIPT REQUESTED
ATTN: EUGENE R EARNST
FLORIDA STEEL CORPORATION
301 BLACK SATCHEL DRIVE
CHARLOTTE, NC 28216
Dear Permittee:
1•�
NCDENR
NORTH CAROLINAkf)fT, PtNT,O� "i�5. iST
ENVIRONMENT ANb N��URAL,RESOURCES,jQr,ES
06/06/2002
`JUN 2 5 2002
-s
Subject: NOTICE OF VIOLATIONA4'��'I'
FAILURE TO SUBMIT RENEWAL APPLICATION
FLORIDA STEEL CORPORATION
NCG030000
COC NUMBER NCG030284
MECKLENBURG COUNTY
This letter is to inform you that, as of the date of this letter, the Division of Water Quality has not received a
renewal request for the subject permit certificate of coverage. This is a violation of NCGS §143.215.1 (c)(I) which
states "Al I applications shall be filed with the commission at least 180 days in advance of the date on which it is
desired to commence the discharge of wastes or the date on which an existing permit expires, as the case may be".
Any permittee that has not requested renewal at least l80 days prior to expiration or permittee that does not have a
permit after the expiration and has not requested renewal at least 180 days prior to expiration, will be subjected to
enforcement procedures as provided in NCGS § 143-215.6 and 33 USC 1251 et. seq.
In order to prevent continued, escalated action, including the assessment of civil penalties you must submit a
completed permit coverage renewal application to the attention of the "Stormwater and General Permits Unit" at
the letterhead address within ten (10) days of your receipt of this letter (renewal application enclosed). If the
subject discharge has been terminated, please complete the enclosed rescission request form. Mailing instructions
are listed on the bottom of the form. You will be notified when the rescission process has been completed.
Thank you for your prompt attention to this situation. If you have any questions regarding this matter, please
contact Mack Wiggins of the central office Stormwater and General Permits Unit at 919-733-5083, ext. 542.
Sincerely,
for Alan W. Klimek, P.E.
Director, Division of Water Quality
cc: Stormwater and General Permits Unit Files
Central Files
Mooresville Regional Office
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 500% recyded(1ON. post -consumer paper

WA
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
EUGENE R ERNST
AMERISTEEL CORP-CHARLOTTE
301 BLACK SATCHEL DR
CHARLOTTE, NC 28216
Dear Permittee:
December 27, 2001
Gregory J_ Thorpe, Ph.D.
Acting Director Y
Division of Water Quality
APR 1 0 2002
Subject: NPDES Stormwater Permit Renewal
AMERISTEEL CORP-CHARLOTTE
COC Number NCG030284 %sI`
Mecklenburg County
Your facility is currently covered for stormwater discharge under General Permit NCG030000. This permit expires
on August 3 t, 2002, The Division staff is currently in the process of rewriting this permit and is scheduled to have
the permit reissued by late summer of 2002. Once the permit is reissued, your facility would be eligible for
continued coverage under the reissued permit.
In order to assure your continued coverage under the general permit, you must apply to the Division of Water
Quality (DWQ) for renewal of your permit coverage. To make this renewal process easier, we are informing you in
advance that your permit will be expiring. Enclosed you will find a General Permit Coverage Renewal
Application Form. The application must be completed and returned by March 4, 2002 in order to assure continued
coverage under the general permit.
Failure to request renewal within this time period may result in a civil assessment of at least $250.00. Larger
penalties may be assessed depending on the delinquency of the request. Discharge of stormwater from your facility
without coverage under a valid stormwater NPDES permit would constitute a violation of NCGS 143-215.1 and
could result in assessments of civil penalties of up to $10,000 per day.
Please note that recent federal legislation has extended the "no exposure exclusion" to all operators of Industrial
facilities in any of the i 1 categories of "storm water discharges associated with industrial activity," (except
construction activities). If you feel your facility can certify a condition of "no exposure", i.e. the facilty industrial
materials and operations are not exposed to stormwater, you can apply for the no exposure exclusion. For additional
information contact the Central Office Stormwater Staff member listed below or check the Stormwater & General
Permits Unit Web Site at hitp://h2o.enr.state.ne.us/su/storrnwater.html
If the subject stormwater discharge to waters of the state has been terminated, please complete the enclosed
Rescission Request Form. Mailing instructions are listed on the bottom of the form. You will be notified when the
rescission process has been completed.
If you have any questions regarding the permit renewal procedures please contact Mike Parker of the Mooresville
Regional Office at 704-663-1699 or Bill Mills of the Central Office Stormwater Unit at [phone], ext. 548
Sincerely,
Bradley Bennett, Supervisor
Stormwater and General Permits Unit
cc: Central Files
Mooresville Regional Office
AMWA
N. C. Division of Water Quality 1617 Mail Service Center Raleigh, NC 27699-1617 [phone] Customer Service
1-800-623-7748

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENTAL QUALITY
DIVISION OF ENERGY, MINERAL, AND LAND RESOURCES
GENERAL PERMIT NO. NCG030000
(ERTUICATUF COVERAGE No NCG030284
STORMWATER DISCHARGES
NATIQNAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful
standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission, and the Federal Water Pollution Control Act, as amended,
CMC Steel US, LLC
is hereby authorized to discharge stormwater from a facility located at
CMC Rebar
2126 Garner Road
Charlotte
Mecklenburg County
to receiving waters designated as an unnamed tributary to Stewart Creek, class C waters in
the Catawba River Basin, in accordance with the effluent limitations, monitoring
requirements, and other conditions set forth in Parts 1, I1, III, and IV of General Permit No.
NCG030000 as attached.
This Certificate of Coverage shall become effective December 20, 2018.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this 20th day of December 2018.
nn
for S. Daniel Smith
Interim Director, Division of Energy, Mineral and Land Resources
By the Authority of the Environmental Management Commission

State of North Carolina
Department of Environment,
Health and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Govemor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
October 1, 1997
EUGENE R. ERNST
AMERISTEEL CORPORATION-CRD
301 BLACK SATCHEL DRIVE
CHARLOTTE, NC 28216
[DEHNF=1
Subject: Reissued Stormwater General Permit for Certificate of Coverage No. NCG030284
Mecklenburg County
Dear Permittee:
In response to your renewal application for continued coverage under the subject permit, the Division
of Water Quality (DWQ) is forwarding herewith the reissued stormwater general permit. This permit
is reissued pursuant to the requirements of North Carolina General Statute 143-215 .1 and the
Memorandum of Agreement between North Carolina and the US Environmental Protection agency
dated December 6, 1983.
The following information is included with your permit package:
■ A copy of the stormwater general permit.
■ A Stormwater Pollution Prevention Plan Certification Form. This form certifies that you have
developed and implemented the Stormwater Pollution Prevention Plan (SPPP) required in your
permit. This form must be completed and returned to the Division within 30 days of receipt of
this letter. DO NOT send the SPPP with the signed form.
w Five copies of Analytical Monitoring forms.
■ Five copies of Qualitative Monitoring forms.
■ A copy of a Technical Bulletin on the stormwater program with outlines program components
and addresses frequently asked questions.
w A corrected Certificate of Coverage if you indicated a name or address change on the Renewal
Form returned to the Division.
Your certificate of coverage is not transferable except after notice to DWQ. The Division of Water
Quality may require modification or revocation and reissuance of the certificate of coverage.
This permit does not affect the legal requirements to obtain other permits which may be required by
DWQ or permits required by the Division of Land Resources, Division of Air Quality, Coastal Area
Management Act or any other Federal or Local governmental permits that may be required.
If you have any questions concerning this permit or other attached documents, please contact the
Stormwater Group at telephone number [phone]
Sincerely,
t5 We7ff
for
. Preston Howard, Jr., P. E.
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10`7o post -consumer paper

STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT, HEALTH AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
GENERAL PERMIT NO. NCG030000
CERTIFICATE OF COVERAGE NO. NCG030284
STORMWATER DISCHARGES
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and
the Federal Water Pollution Control Act, as amended,
AMERISTEEL CORPORATION-CRD
is herby authorized to discharge stormwater from a facility located at:
301 BLACK SATCHEL DRIVE
CHARLOTTE, NC
MECKLENBURG COUNTY
to receiving waters designated as UT To Stewart Creek in the CATAWBA River Basin
in accordance with the effluent limitations, monitoring requirements and other conditions set forth in Parts I,
II, III and IV of General Permit No. NCG030000 as attached.
This Certificate of Coverage shall become effective September 15, 1997
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day October 1,1997
for A. Preston Howard, Jr., P.E., Director
Division of Water Quality
By Authorization of the Environmental Management Commission

StiVe of North Carolina
{ Department of Environment,
Health and Natural Resources
Division of Environmental Management
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
A. Preston Howard, Jr., P.E., Director
April 29, 1994
Mr. Eugene R. Ernst
Florida Steel Corp.
P.O. Box 31328
Tampa, FL. 33631
�EHNF�
Subject: General Permit No. NCG030000
Florida Steel Corp.
COC NCG030284
Mecklenburg County
Dear Mr. Ernst:
In accordance with your application for discharge permit received on April 29, 1994, we are forwarding
herewith the subject certificate of coverage to discharge under the subject state - NPDES general permit. This
permit is issued pursuant to the requirements of North Carolina General Statute 143-215 .1 and the
Memorandum of Agreement between North Carolina and the US Environmental Protection agency dated
December 6, 1983.
If any parts, measurement frequencies or sampling requirements contained in this permit are
unacceptable to you, you have the right to request an individual permit by submitting an individual permit
application. Unless such demand is made, this certificate of coverage shall be final and binding.
Please take notice that this certificate of coverage is not transferable except after notice to the Division
of Environmental Management. The Division of Environmental Management may require modification or
revocation and reissuance of the certificate of coverage.
This permit does not affect the legal requirements to obtain other permits which may be required by the
Division of Environmental Management or permits required by the Division of Land Resources, Coastal Area
Management Act or any other Federal or Local governmental permit that may be required.
If you have any questions concerning this permit, please contact Mr. Bill Mills at telephone number 919/733-
5083.
Sincerely,
original signed
13
Coleen H.
ns
A. Preston Howard, Jr., P. E.
cc: Mooresville Regional Office
Mecklenburg County
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

\„
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENT, HEALTH, AND NATURAL RESOURCES
DIVISION OF ENVIRONMENTAL MANAGEMENT
STORMWATER DISCHARGES
In compliance with the provision of North Carolina General Statute 143-215.1, other lawful standards and
regulations promulgated and adopted by the North Carolina Environmental Management Commission, and the
Federal Water Pollution Control Act, as amended,
Florida Steel Corporation
is hereby authorized to discharge stormwater from a facility located at
Florida Steel Corporation
301 Black Satchel Drive
Charlotte
Mecklenburg County
to receiving waters designated as an unnamed tributary to Stewart Creek in the Catawba River Basin
in accordance with the effluent limitations, monitoring requirements, and outer conditions set forth in Parts I, II, III
and IV of General Permit No. NCG030000 as attached
This certificate of coverage shall become effective April 29, 1994.
This Certificate of Coverage shall remain in effect for the duration of the General Permit.
Signed this day April 29, 1994. g,
Q�i�nal Signe�«1�:
Coleen VA. 50
A. Preston Howard, Jr., P.E.
Division of Environmental Management
By Authority of the Environmental Management Commission

7-1
rr
rt
!w C&,Si7Odb1NNb'31 N 11'S
. `k - - fi, ! !a 's-n of 'rw r I o ,s D "N of 'rw f r fi N
'1 �� �'_�.•`-��`'>� �-- � / -��/1 `�A �{'i0 i•yf{} ��, �� i"'f� V - J.�'.. �� �0�, �� � �� 7- �V "�^�'� _�
`ate. / ' I/ m I, 1 ,.'"r � •��• i r
fit•, J;�/J� � '.i�: ��/��� •)�l r� ��1���',�.o��i����,,-�;:,, \, � •� � ,r� �.� _ 1` ��� �� �
jJ/ 1 a !,� - a � � LoLi
f � ' �_ C � � �� :' _\ •�: 1 / J f �G�, ��•,�/ {� � � i, l� -0! � µ YEN ; ^F./ttl �t f '�. " _ _ .-:' = Z
kii
lam
� � ti�L i� •. . L l 1 f C ``fir I • i �.� ' ' �./ � - ap hi � S ;: •) l.` aP � /. ;� \ � �, � �1 ��,-
' 1i�✓�1 � �Dy r ��.��'�—•,•.�.�� ��--� °� 1�ff� � � , � ��J•I►�, �. "�� ' �y - � ✓�%_�,� piµ �' �A JJ����_..�. �' o �
L��• �(� � _` ,,• %�/ 1 ~ �', �tj � H..\ \" , i �`y rr% � f��._ 1\f' 1. , d�;--O[
•� n i
'''�•^\/' •'�\\�\ \f/�! ��5�/ �� ��J%--��� fin/l�/)y���_ �• _��_i .`--'�' 1 - / _ l H
'�r•••i.`•� n.'?��) � 'r^"'� y lo�� �\ r. 'flil�� ••:� .�•�m �, m
��I )� � •, �-�e�l {� �� ��' 11 C • �../,• t Z ) � ,� (`J{ ''�L�� � p 1 1I � - •!` ' cv
41
`� "ISM ����1�� \��.�f" � .� /`'- -�,� C- _ -_ .`��• �� _- [_';� J � ��.• � �_ �� '� \\ ��� l (n> �� ,%�\\� n��.
LO
1�,1.`. ;-r�froS������ �� �-?1�'��' `�J �8=�-�� _i'� �•-•7 $l-��. .� ��y�./ �1��� ~I!\\�1Y ��• j%'J,' `Vl� ;Ir1l�~y:�
8 I _ L.n c J_ �'`1 ti_ lid ��rs },{._ �l:\�Y�r! �✓
�-
`� \\�J• MAN-
/�l �h �J �lv����/rti. L {•. ..` w ri: �y='. ` Lp\`i 3 • •`�',a '� �;,' �" • �� J �j/. ✓wj.{���bd J�/ r�%C� D 1�,./�1 `

FACILITY F Lug 6Pr STEEL C'o'zP t Ghct 2:10 ejl?-ba.e. T>+V.
COUNTY Me-cxtw6 rq
NPDES Ncr,03 0aa4
MAP #
DSN'FLOW
,,p�,SUB`, BASIN
LATTITUDE
F i5svj
Q/ A
0 3 o
3S ° 1-1 1 o 3.,
LONGITUDE <i�o ° 53 ` ocp "
RECEIVING STREAM
STREAM CLASS C.
DISCHARGE TYPE
W r �m Sk,,j a 4- C -zx,
5W
EXPIRATION DATE oa 13 k j R'1