820545_CORRESPONDENCE_20171231

NUK I H UAHULINA
Department of Envimnmental Qual

VLTX-
1
NCDENR
Nord Carolina Department of Environment and'Natural Resources
Division of Water QualityK
Beverly Eaves HerdueColeen H. Sullins �., pi":-'�[���� -ADee Freeman
Governor Director t --. ry� Secretary
VRA`, 2
May 13, 2010 1�
Craig P. Collins FRO
Craig Collins Farm
202 W Arrowhead ,
Clinton, NC 28328
Subject: Certificate of Coverage No. AWS820545
Craig Collins Farm
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
Dear Craig P. Collins:
In accordance with your May 11, 2010 request to correct the currently permitted animal capacity and to
change the operation type to match the corrected steady state live weight, we are hereby forwarding to
you this Certificate of Coverage (COC) issued to Craig P. Collins, authorizing the operation of the subject
animal waste management system in accordance with General Permit AWGIOOOOO. The permit
correction involves the inclusion of 387 gilts that were inadvertently omitted from the previous COCs that
only showed 364 Farrow to Feeder animals.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for the Craig Collins Farm., located in Sampson County, with a swine animal capacity of
no greater than the following annual averages:
Wean to Finish: Feeder to Finish: Boar/Stud:
Wean to Feeder: Farrow to Wean: 516 Gilts:
Farrow to Finish: Farrow to Feeder: Other:
If this is a Farrow to Wean or Farrow to Feeder operation, there may be one boar for each 15 sows. Where
boars are unnecessary, they may be replaced by an equivalent number of sows. Any of the sows may be
replaced by gilts at a rate of 4 gilts for every 3 sows.
The COC shall be effective from the date of issuance until September 30, 2014, and shall hereby void
Certificate of Coverage Number AWS820545 dated October 1, 2009. Pursuant to this COC, you are
authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Please pay careful attention to the
record keeping and monitoring conditions in this permit. Record keeping forms are unchanged with this
General Permit. Please continue to use the same record keeping forms.
1636 Mail Service Center, Raleigh, North Carolina 27699.1636
Location: 2728 Capital Blvd Raleigh, North Carolina 27604 One
Phone: [phone] FAX; 919-715-M I Customer Service: 1.877-623-6748 NorthCarolina
Internet vrww.nawaOertluality.atg '�'j����� /��
An Equal Opportunity 1 Affit rubw Amon Employer � �/ L

If your Waste Utilization Plan (WUP) has been developed based on site-specific information, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Per 15A NCAC 2T .0105(h) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100 -foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, then an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A nacre/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Unit for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition I1.22 of the General Permit. waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Tropical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You
may find detailed watch/waming information for your county by calling the Raleigh, NC National
Weather Service office at [phone], or by visiting their website at: www.erh.noaa.gov/er/rah/
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Aquifer Protection Staff may be reached at [phone]. If you need additional information
concerning this COC or the General Permit, please contact the Animal Feeding Operations Unit staff at
[phone].
Sincerely,
for Coleen H. Sullins
Enclosure (General Permit AWG 100000)
cc: (Certificate of Coverage only for all ccs)
Fayetteville Regional Office, Aquifer Protection Section
Sampson County Health Department
Sampson County Soil and Water Conservation District
APS Central Files (Permit No. AWS820545)
A1"O Notebooks
Prestage Farms Inc

Grower(s):
Farm Name:
NUTRIENT UTILIZATION PLAN
Craig Collins
Craig Collins
County: Sampson
Farm Ca ac' :
Farrow to Wean
Farrow to Feeder 364
Farrow to Finish
Wean to Feeder
Gilts 387
Storage Structure:
Storage Period:
Application Method:
Anaerobic Lagoon
>180 days
Irrigation
RECEIVED
PAR,? 51005
L- AVTEitff REftga �,Rrf
RECEIVED I DEAR I DWQ
AQUIFFR'PRnTFrrinN RFCTiON
MAR 19 2009
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value. of the waste and to ensure that it is applied in an environmentally safe manner:
1: Always apply waste based on the needs of the crop to be grown and the nutrient .
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems. A
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ff, tons, etc.):
Capacity Type Waste Produced per Animal Total
Farrow to Wean
3212 gal/yr
gal/yr
364
Farrow to Feeder
4015 gal/yr
1,461,460 gal/yr
Farrow to Finish
10585 gal/yr
gal/yr
Wean to Feeder
223 gal/yr
gatlyr
387
Feeder to Finish
986 gal/yr
381,582 gal/yr
Total 1,843,042 gallyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs):
Capacity Type Nitrogen Produced per Animal Total
Farrow to Wean
5.4 lbs/yr
lbs/yr
364
Farrow to Feeder
6.5 lbs/yr
2,366 lbs/yr
Farrow to Finish
26 lbs/yr
lbs/yr
Wean to Feeder
0.48 lbs/yr
lbs/yr
387
Feeder to Finish
1.15 lbs/yr
445 lbs/yr
Total 2,811 lbs/yr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 9.63
Total N Required 1st Year: 3033.45
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops: 3,033.45
Total Nitrogen Produced by Farm: 2,811.05
Nitrogen Balance for Crops: (222.40)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2of8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code Crop
A Barley
B Hybrid Bermudagrass - Grazed
C Hybrid Bermudagrass - Hay
D Com - Grain
E Com - Silage
F Cotton
G Fescue- Grazed
H Fescue - Hay
I Oats
J Rye
K Small Grain - Grazed
L Small Grain - Hay
M Grain Sorghum
N Wheat
O Soybean
P Pine Trees
Lbs N utilized / unit yield
1.6 lbs N / bushel
50 lbs N / ton
50 lbs N /ton
1.25 lbs N / bushel
12 lbs N /ton
0.12 lbs N / lbs lint
50 lbs N / ton
50 lbs N /ton
1.3 lbs N / bushel
2.4 lbs N / bushel
50 lbs N / acre
50 lbs N / acre
2.5 lbs N/cwt
2.4 lbs N / bushel
4.O lbs N / bushel
40 lbs N / acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4 of 8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications
PAN/ danimat Farm Total/yr
Farrow to Wean
0.84
364 Farrow to Feeder
1 354
Farrow to Finish
4.1
Wean to Feeder
0.072
3137 Feeder to Finish
0.36 139.32
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements_ Your production facility will produce
approximately 503.32 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 2516.6 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 8 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 20.1325 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to property
irrigate the acres shown in the preceding table_ Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
'This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions,
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
6of8
Soil
Application Rate
Application Amount
Tract
Hydrant
Type
Crop
in/hr
* inches
9219
1
To
C
0.45
1
9219
2
To
C
0.45
1
9219
3
To
C
0.45
1
6of8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: Craig Collins
Owner: Craig Collins
Manager:
Owner/Manager Agreement:
Vwe understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Craig Collins
Signature:
Name of Manager (if different from owner):
Signature:
Date
Name of Technical Specialist: Kraig Westerbeek
Affiliation: Private
Signature:
Address: 1635 W. Wards Bridge Rd.
Warsaw, N 28398
Telephone: 10) 293A87
-3 �7
Date
f
f
1
8of8

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P. E., Director
Division of Water Quality
October 1, 2004 1 RECEIVED
Craig Collins OCT 15 2094
Craig Collins Farm OENR--FAYETTEVIf_LEREfIQlVA!_OFRGE
202 West Arrowhead
Clinton NC 28328
Subject: Certificate of Coverage No. AWS820545
Craig Collins Farm
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
Dear Craig Collins:
On June 11, 2004, the North Carolina Division of Water Quality (Division) issued a revised State General
Permit for swine facilities. The General Permit was issued in accordance with the directive of Senate Bill
733 (Session Law 2403-28).
In accordance with your application received on February 25, 2003 and in accordance with the directive
of Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to Craig
Collins, authorizing the operation of the subject animal waste collection, treatment, storage and land
application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AWS820545 which expires October 1, 2004.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Craig Collins Farm, located in Sampson County, with an animal capacity of no
greater than an annual average of 364 Farrow to Feeder swine and the application to land as specified in
the facility's Certified Animal Waste Management Plan (CAWMP). if this is a Farrow to Wean or
Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary,
they may be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a
rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this CDC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Since this is a revised State
General Permit, it contains new requirements in addition to most of the conditions contained in the
previous State General Permit. Enclosed for your convenience is a package containing the new and
revised forms used for record keeping and reporting. Please pay careful attention to the record kmin
and monitoring conditions in this permit.
Aquifer Protection Section — Animal Feeding Operations Unit
1636 Mail Service Center, Raleigh, North Carolina 27699-1638
Phone; 919-733-3221 1 FAX: [phone] Internet: h2o.enr.state.nc.us
An Equal Opportunity/Affirmative Action Employer — 50% Recycled110% Post Consumer Paper
NorthCarolina
Naturally

If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you .will need to.have a. new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 2H .0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100 foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Duane Leith at [phone].
Sincerely,
-d -
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG 100000)
cc: (Certificate of Coverage only for all cc's)
Fayetteville Regional Office, Aquifer Protection Section
Sampson County Health Department
Sampson County Soil and Water Conservation District
Permit File AWS820545
APS Central Files

powInt&' �j
NCDENR
North Carolina Department of Environment and Natural Resources
Michael F. Easley, Governor
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
April 30, 2004
Craig Collins
Craig Collins Farm, Facility # 82-545
202 West Arrowhead
Clinton, NC 28328
Dear Mr. Craig Collins
William G. Ross Jr., Secretary
Alan W. Klimek, P.E., Director
Coleen H. Sullins, Deputy Director
Division of Water Quality
This letter is in response to your question about filling out column 8 on the Irr-2 form that was asked
during the inspection of your farm on 4-20-04. After discussing the issue with other DWQ staff members
it was determined that the actual field size should be used in the calculations. I have also talked to the
local soil and water division and they are in agreement also. I have attached an example IRR -2 form to
this letter_ If you have any questions please call me at 910-486-1541 ext. 730.
Thank you
A'1 &f -e
Mark Brantley
Environmental Specialist
Cc: Tent Allen, Fayetteville Regional Office
225 Green Street — Suite 714, Fayetteville, North Carolina 28301-5043
Phone: [phone] FAX: [phone]Internet: ww.enr.state.nc.us/ENIt/
An Equal Opportunity / Affirmative Action Employer - 50 %Recycled 1 10 °!o Post Consumer Paper
NorthCarolina
Aaturall'ff
-

t -w FORM IRA -2
Hydran
Field Size (waited acres)
Farm Owr
Owner's Addre
Owners Phon(
A L
Lagoon Liquid Irrigation Fields Record
One Form for Each Field per Crop Cycle
Crop Type
1). 3 4 5 B)
Facility Number
Irrigation Operator
Irrigation Operator's
Address
Operators Phone p
From Wasis Utilization Plan
Recommended PAN
Loading (lb/acre) = (B)
T 8 9 10 ' 11
—Nutdanl
Source
Dale
(mnVdd/yr)
Irri alien
Waste Analysis
PAN'
(IN 1000 gal)
PAN Applied
(lb/acre)
ral x to
I e ya�,.r 1.
Nitrogen
Balance"
(lblacre)
(B) . 00)
Slarl
Time
End
Time
Tolal
Minutes
(3) • (2)
Not
Sprinklers
Operating
Flow
Rete
(gallmin)
Total Volume
(gallons)
(9) x (5) x (4)
3a
Volume
per Acre
(gallacre)
c (T)1(A)
l vv t? c�, S83
GA con
0 L'
0,3
S c,
301,-'700U
11,37
.3/.
Crop Cycle 7aials
Owners Signature
Certified Operator (Print)
Operalor's Signature
Operator's Certification No.
NCUA Waste Anaylsis or Equivalent, At a minimum, waste analysis is required within 60 days of land application events.
Enter the value received by subtracting column (10) from (0). Continue subtracting column (1a) from column (11) following each irrigation event. „3/ 14/03
"'Enter i nl source (le. LagoonlSiorage Pond ID, commerical fertilizer, dry fitter, etc.)

Axlm
NENR
North Carolina Department of Environment and Natural Resources
Michael F. Easley, Governor
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
April 30, 2004
Craig Collins
Craig Collins Farm, Facility # 82-545
202 West Arrowhead
Clinton, NC 28328
Dear Mr. Craig Collins
William G. Ross Jr., Secretary
Alan W. Klimek, P.E., Director
Coleen H. Sullins, Deputy Director
Division of Water Quality
This letter is in response to your question about filling out column 8 on the Irr-2 form that was asked .
during the inspection of your farm on 4-20-04. After discussing the issue with other DWQ staff members
it was determined that the actual field size should be used in the calculations. I have also talked to the
local soil and water division and they are in agreement also. I have attached an example IRR -2 form to
this letter. If you have any questions please call me at 910-486-1541 ext. 730.
Thank you
/W '6"tl, 4-
Mark Brantley
Environmental Specialist
Cc: Tent Allen, Fayetteville Regional Office
225 Green Street - Suite 714, Fayetteville, North Carolina 28301-5043
Phonc: 910-486-1541 1 FAX: [phone] Internet: ww.enr.state.nc.us/ENR/
An Equal Opportunity; Affirmative Action Employer — 30 %Recycled 1 10 % Post Consumer Paper
NorthCarolina
Naturallff

FORM IRA -2
Hydran
Field Size (waited acres) a
Farm Owr
Owner's Addre
Owners phony
Lagoon Liquid Irrigation Fields Record
One Form for Each Field per Crop Cycle
Crop Type
'011. 2 3 4 5 6
Facility Number
Irrigation Operator
Irrigation Operator's
Address
Operators Phone It
From Waste Utilization Plan
Recommended PAN
Loading (Ib/acre) = (9)
7 8 9 1Q 1t
"'Nutrient
Source
bate
(mm/ddlyr)
Irr'notion
Waste Analysis
PAN'
(IWf000 gel)
PAN Applied
(IWacre)
(8) x f91
11700
I6 4,1-1--A 1 2
Nitrogen
Balance"
(IWacre)
la) {tt1)
Start
Time
End
Time
Total
Minutes
(3)-(2)
Not
Sprinklers
Operating
Flow
Rate
(gaVmin)
Total Volume
(gallons)
(8) x (5) K (4)
3,•a / x3d
Volume
per Acre
(gavacrs)
(7) I IA)
ylUoac�,S83e=
SC
LG eon
.31r.�
Crop Cycfe Talefal
Owners Signature Operator's Signature
Certified Operator (Print) Operator's Certification No.
` NCDA Waste Anaylsis or Equivalent. At a minimum, waste analysis is required within 60 days of land application events.
" Enter the ,value received by subtracting column (10) from (B). Continue subtracting columr2 (10) Irom column (11) following each irrigation event x3/14/03
c.}
"'Enter 1 nl source (le. Lagoon/Storage Pond ID, commerical fertilizer, dry litter, at `

Awlk s
Animal Waste Management Plan Certification
(Please tvov or print all information that does not reauirc a signature)
gz -5-,s—
fEx tines or New or Expanded (please circle one) j
General Information:
Name of Farm: CRAI& Cat.L414 R Facility No:
82- -- SAF 5
Owner(s) Name: Phone No: 916 - 59 2 -9 ace
Mailing Address: Zoz g — AltRoWHEAD CLrPIToN Ne- 2.83M
Farm Location_ County Farm is located in: SAmP v4
Latitude and Longitude: 78' V7' 44" 13V Lflu Integrator: TACE F#gms e,
Please attach a copy of a county road map with location identified and describe below (Be specific: road
names, directions, milepost, etc.): W o x. / M 04LE 61 W a F IreRit o N R i L
� J
A
M y
e
Operation Description: �m
\Type of Swine Na. of Animals T} pe of Poulin No. of Animals Type of DairyF Illof Anus n :^
).0 Wean to Feeder 4 G Laver G Milking i
� J Feeder to Finish Z y 0 Non -Layer 0 Dry
0 Farrow to Wean ` Type of Beef No. of Animals ❑ Heifer's ? •r
\ Farrow to Feeder 0 Broad U' Calves
yr X 0 Farrow to Finish 1 0 FeedersVn L
IL
its
d Stockers D
V0 Boars Other Type of Livestock: Number of Animals: l
Erpwzang operation Only
a' Oji Previous Design Canaciry: Additional -Design Ca acitw' Totttf Desi n Capacim.
Acreage Available for Application:_ l s' Required Acreage: ! Q? 4.
'wumber of Lagoons / Storage Ponds: 1 Total Capacity: 4 5 Lw 3 D 4 Cubic Feet (R3)
Are subsurface drains present on the farm:. YES or NO (please circle one)
��If YES: are subsurface drains present in the area of the: LAGOON or SPRAY FIELD (please circle one)
Owner I Manager Agreement
E I (we) verity that all the above information is correct and will be updated upon changing. i (we) understand the operation and
a maintenance procedures established in the approved animal waste management plan for the farm named above and will
implement these procedures. I (we) know that any expansion to the existing design capacity of the waste treatment and storage
system or construction of new facilities will require a new cenifcation to be submitted to the Division of water Quality
-? (DWQ) before the'new animals are stacked. I (we) understand that there must be no discharge of animal waste from the
storage or application system to surface waters of the state either directly through a man-made conveyance or from a storm
event less severe than the 2.5 -year.. 24-hour storm and there must not be run-off from the application of animal waste. 1 (we)
understand that run-off of pollutants from lounging and heovy use areas trust be minimized using technical standards
developed by the USDA -Natural Resources Conservation Service (NRCS). The approved plan will be filed at the farm and at
the office of the local Soil and Water Conservation Disuict. I (we) know that any modification must be approved by a
technical specialist and submitted to the Soil and Water Conservation District prior to implementation. A change in land
ownership requires written notification to DWQ or a new certification (if the approved plan is changed) within 60 days of a
title transfer. -17 . i
Name of L
Signature:
Name of X
Signature: Date:
AWC -- December M00 I

- State of North Carolina
Department of Environment,
Health and Natural Resources
Fayetteville Regional Office
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
A4
DEHNR
DIVISION OF ENVIRONMENTAL MANAGEMENT
April 11, 1996
Mr. Craig Collins
202 West Arrowhead Rd.
Clinton, NC 28328
SUBJECT: Craig Collins Farm
Reg. # 82-545
Sampson Co.
Dear Mr. Collins,
On 2/13/96 and 4/4/96 staff from the Fayetteville Regional
Office of the Division of Environmental Management inspected your
animal operations and the lagoon serving this operation. It was
observed on both inspections that the existing lagoon did not have
the sufficient freeboard of one foot and seven inches for the 25
year 24 hour storm event.
In order to properly correct the deficiency listed above, it
is required that the lagoon level should be lowered immediately via
the spray application of waste material at agronomic rates on a
viable cover crop to avoid runoff. The application of this waste
should be observed by farm staff to prevent runoff of any waste
from this site.
It has been noted that you are currently planning to raise the
low corner of the lagoon in the near future. However, to remain a
deemed permitted facility, all corrective actions must be made by
May 13, 1996. Failure to do so may result in the facility losing
it's deemed permitted status, requiring you to apply for an
individual non -discharge permit for the facility.
Please be aware it is a violation of North Carolina General
Statutes to discharge wastewater to the surface waters of the State
without a permit. The Division of Environmental Management has the
authority to levy a civil penalty of not more than $10,000.00 per
day per violation.
Wachovia Building, Suite 714, Fayetteville FAX [phone]
North Carolina 28301-504,3 CNif An Equal Opportunity Affirmative Action Employer
Voice 910-466-1541 5096 recycled/10% post -consumer paper

Mr. Collins
Page 2
4/11/96
When the required corrective actions are complete, please
notify this office in writing at the address below. If you have
any questions concerning this matter, please call Ed Buchan or
Michael Wicker at [phone].
Wachovia Bldg.
Suite 714
Fayetteville, NC 28301-5043
Sincerely,
Ed Buchan
Environmental Engineer I
cc: Wilson Spencer - Sampson Co. NRCS
Chris Walling - Soil and Water Conservation (Fayetteville)
Dianne Wilburn - Facility Complaince Unit (Raleigh)

1,, n 4
-T6 -L)1064" a HAnneweo+
ilp_ IOi�R� fjce
• I jj
�J
Aye �
Vi Ile � � i, = 2-9301 "50
Troon � C. � 5 �. Co �� ms W(6 t�,r►-�
82-5q5
In r �UA4s -io your- Afil � IIS correspov�dcv)ce,
4e 1e''�-iciew,�c! I,) ,,psi-ra�� kqs- bc.�n earrc�+�
Apt,I Ib��996,�'Pie4lve--JP�1 JW -cc
7itE Co�- j-aG�oYl
nilykni �C zeszs'
U
APR 17
ENV. MANAGEMENT
FAYETTEVILLE REG. OFFICE

State of North Carolina
Department of Environment
and Natural Resources
Divisicn of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
Craig Collins
Craig Collins Farm
202 West Arrowhead
Clinton NC 28328
Dear Craig Collins:
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
October 22, 1999-
DECEIVED
NOV 0 2 1999
WE.T ITEM CEE
REG
Subject: Certificate of Coverage No. AWS820545
Craig Collins Farm
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
In accordance with your application received on March 19, 1999, we are forwarding this
Certificate of Coverage (COC) issued to Craig Collins, authorizing 'the operation of the subject animal
waste collection, treatment, storage and land application system in accordance with General Permit
AWG100000. This approval shall. consist of the operation of this system including, but not limited to,
the management of animal waste from the Craig Collins Farm, located in Sampson County, with an
animal capacity of no greater than 364 Farrow to Feeder and the application to land as specified in the
Certified Animal Waste Management Plan (CAWMP). _
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations
as specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by.
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General
Permit or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS
143-215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This
request shall be made within 30 days of notification by the Division.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Certificate of Coverage AWS820545
Craig Collins Farm
Page 2
This COC is not automatically transferable. A name/ownership change application must be
submitted to the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the `
right to apply for an individual non -discharge permit by contacting the engineer listed below for
information on this process. Unless such a request is made within 30 days, this COC shall be final and
` binding.
The subject farm is located in the Fayetteville Regional Office. The Regional Office Water
Quality Staff may be reached at [phone]. If you need additional information concerning this
COC or the General Permit, please contact JR Joshi at [phone] ext. 363.
cc: (Certificate of Coverage only for all cc's)
Sampson County Health Department
Fayetteville Regional Office, Water Quality Section
Sampson County Soil and Water Conservation District
Permit File
NDPU Files

State of North Carolina
Department of Environment and Natural Resources
Division of Water Quality
Non -Discharge Permit Application Form
(THIS FORM A14 Y BE PHOTOCOPIED FOR USE AS AN ORIGINAL)
General Permit - Existing Liquid Animal Waste Operations
820. svr
fro
The following questions have been completed utilizing information on file with the Division. Please
review the information for completeness and make any corrections which are appropriate. If a
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
I. GENERAL INFORMATION:
1.1 Facility Name: Craig Collins Farm
1.2 Print Land Owner's name: Craig Collins
FECEIVED
V 0. Z 1999;
1.3 Mailing address: 202 West Arrowhead E
City, State: Clinton NC Zip: 28328 REG. C
Telephone Number (include area code): 910-532-4849 or 592-9008
1.4 County where facility is located: Sampson
1.5 Facility Location (Directions from nearest major highway. Please include SR
numbers for state roads. Please include a
copy of a county road map with the location of the farm identified): Approx.
I mile NW of Kerr on SR 1 121
1.6 Print Farm Manager's name (if different from Land Owner):
1.7 Lessee's / Integrator's name (if applicable; please circle which type is listed):
Presta a Farms
1.8 Date Facility Originally Began Operation: 01/01/86
1.9 Date(s) of Facility Expansion(s) (if applicable):
2. OPERATION INFORMATION:
2.1 Facility No.: _82 (county number); ____545 (facility number).
2.2 Operation Description: Swine operation
Farrow to Feeder
364- Certified Design Capacity
Is the above information correct? [./]yes; F__Jno. If no, correct below using the design capacity of the facility
The "No. of Animals" should be the maximum number for which the waste management structures were designed_
Type of Swine No. of Animals Type of Poultry No. of Animals
Type of Cattle No. of Animals
0 Wean to Feeder 0 Layer
0 Dairy
0 Feeder to Finish 0 Non -Layer
0 Beef
0 Farrow to Wean (4 sow) 0 Turkey
0 Farrow to Feeder (# sow)
0 Farrow to Finish (# sow)
Other Type of Livestock on the farm:
No. of Animals:
RECEI
YAC 1JAMYSECnON
MAR 1 9 1999
FORM: AWO-G-E 5128198 Page 1 of 4 82 - 545
Non-Discha.,ge Permitting

0
2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): 12 ; Required Acreage (as listed in the AWMP): 12
2.4 Number o oo storage ponds (circle which is applicable): t
2.5 Are subsurface drains present within 100' of any of the application fields? YES or /N(Y (please circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES or�N� (please circle one)
2.7 Does this facility meet all applicable siting requirements? (Swine Fame Siting Act, NRCS Standards, etc.) (Swine Only)
(�'Tsjor NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited? 1985
What was the date that this facility's land application areas were sited? 1985
REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signingyour initials in the space provided next to each
item.
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). if the facility
does not have a CAWMP, it must be completed prior to submittal of a �,eneral permit
application for animal waste operations.
The CAWMP must include the following components:
3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application.
3.3.4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application field.
3.3.8 The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
33.10 A site schematic.
3.3.1 I Emergency Action Plan.
3.3.12 Insect Control Checklist with chosen best management practices noted.
3.3.13 Odor Control Checklist with chosen best management practices noted.
3.3.14 Mortality Control Checklist with the selected method noted.
3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility.
3.3.16 Operation and Maintenance Plan.
If your CAWMP includes any components not shown on this list. please include the
additional components with your submittal.
FORM: AWO-G-E 5128198 Page 2 of 4 82-545
Applicants Initials
f6
eA41
CPdl

WAR 0
Facility Number: 82 - 545
Facility Name: Craig Collins Farm
4. APPLICANT'S CERTIFICATION:
9 �9;9
1, CRAIG CALL !J 5 (Land Owner's name listed in question 1.2), attest that
this application For CRAM Cc LLi CJS F -ARM (Facility name listed in question I.I)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not include , this application
package will be re ed to m s Inco plete.
Signature Date
5. MANAGER`S CERTIFICATION: (complete only if different from the Land Owner)
(Manager's name listed in question 1.6), attest that this
application for (Facility name listed in question 1.])
has been reviewed by rue and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned as incomplete.
Signature
Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-035
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
FORM: AWO-G-E 5128198 Page 3 of 4 82-545

,. �•� R r.
nll •. f e
bSf s• wpr.aN 1111
- lir
` IYL IIV N71 ITO rNl b �4 '
9, 'y
StrAb 14L
1!V IN/
1t use .1• tool Il11
,�
70
11I�[
..r V ICU/ !
i FNM �d lraa JrH 1.N +'�` d2, IMl , I.r ••'/. Gouroob 11Y \
V. r G i
RA.l.pb.a Yiap, IL11 ' A� _ 111111 -- 1-- s � 1t t \ ,a X10,
S a ;< rJ
IUl Int 04411' 1411
1 N
�. RJ[lS
1,11 Rip ERR, �',`:, r .'. '\
LL llF2 ► q. N „1j IaQi IIY
Avg. 3� . t1«ir�f •; �� a.. 1.. r' -✓•4
am 111.
L1Nr �'.
MO na•' ` 1 {� Sar ,\
IN „1l � Ila eN"°(L P►� � �I,r
ill
u,f ae yl RP u7i �T� kin w �i �4y 4 p1 10"
JN A. G
'
It
s �\
v u,l :� 6 It � r. /}� � f-•- ��. 111. \ 1 illi 'i1Y �� '�
MI
uil
l u q p, l 4 Rp � I I N -4 f 1•P0. r I R I �1r 1 �., i \� k.
J \ 'F w I�1 C4w I-
FIFE aw At �Y�•,� �r '\
i.
.nl 1n Rq ❑Jl. W
IllL
Inlr l'0.1 IY. lot R0. ,IN e �II .Ra
N IIUCK al,
lf( Lnnho. 1 I IOI
�• ,yaq 4 .i�
LEA
paMrt SS ReNtS' sz-.xA ,NJ rF,p! a� A ekr \
r Y
ln1 IIY Iae1 f17• 4... e. �\
nY
IrY,a Ilr1 t , IIr' "! � IIY II I kIINY Kw1 RO 1,11 I..44`
b1 � Ilil :;a A0..
Rn.
N00.FIi � I}II leweMoA
17Jt 0 Li1J Int
all v
Ilk[ ry C •
I/r nu -t ^f'
4141,
Qaap,p
s
1m. ,� Ip. lm
J i
V:r
l7Y � +NJ IM IIY N
+ .�• P+vs r �•�.. 2, v
71
70
0
Ins 10 E pry„
K
It
D E
A
L
6
r

WASTE UTILIZATION PLAN pAbE I
August 26, 1996
PRODUCER: Craig Collins
LOCATION:202 West Arrowhead i
Clinton NC 28328
TELEPHONE: [phone]
TYPE OPERATION: Farrow to Feeder Swine
I�
NUMBER OF ANIMALS: 456 sows design capacity
The waste from your animal facility must be land applied at a specified
rate to prevent pollution of surface and/or groundwater. The plant
nutrients in the animal waste -should be used to reduce the amount of
commercial fertilizer regni-red for the crops in the fields where waste
is'to be applied. This waste utilization plan uses nitrogen as the
limiting nutrient. Wase should be analyzed before each application
cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally sate manner. Always
apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can
utilize. Soil typEs are important as they have different infilitration
rates, leaching potentials, cation exchange capacities, and available
water holding capacities. Normally waste shall not be applied to land
eroding at greater than 5 tons per acre per year. With special pre-
cautions, waste may be applied to land eroding at up to 10 tons per
acre per year. Do not apply waste on saturated soils, when it is
raining, or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed under DEM
regulations. Wind conditions should also be considered to avoid drift
and downwind odor problems. To maximize the value of the nutrients
for crop production and to reduce the potential for pollution, the
waste should be applied to a growing crop or applied to bare ground
not more than 30 Cays prior to planting. injecting the waste or
disking will conserve nutrients and reduce odor problems.
This plan is based on waste application through irrigation for this
is the manner in which you have chosen to apply your waste. If you
choose to inject the waste in the future, you need to revise this
plan. Nutrient levels for injecting waste and irrigating waste are
not the same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage require-
*ents should be -based on the waste analysis report from your waste
management facility. Attached you will find information on'proper
sampling techniques, preparation, and transfer of waste samples to
the lab for analysis.
This waste utilization plan, if carried out, meets the requirements
for compliance with 15A NCAC 2H.0217 adopted by the Environmental
Management Commission.

I
WASTE UTILIZATION PLAN PAGE %2
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.) f
456 sows x 7.3 tons waste/sows/year = 3328.6 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR i
456 sows x 6.5 lbs'PAN/sows/year = 2964 lhs.,PAN/year
Applying the above amount of waste is a big job. You should plan time
and have appropriate equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
TABLE 1: ACRES OWNED BY PRODUCER 1
TRACT
FIELD
SOIL -TYPE & CLASS=
CROP
YIELD
LBS
COMM N
**
* LBS
B�
, �.
DETERMINING PHASE
CODE
g
ATN N
PER
ACRES
AW
•`� 6
IA LeA
SC
�
PER AC
AC
USED
APPLIC
TIME
9219
1
To
BH 'S.3
265
9
2385
MAR -OCT
9219j1P_ LeA BH 4.0 1200J 3 1600
J I MAR -OCT
— — TOTAL12965
-- indicates that this field is being overseeded (i.e. interplanted)
or winter annuals follow summer annuals.
NOTE: The applicator is cautioned that P and K may be over applied
while meeting the N requirments. Beginning in 1596 the Coastal Zone
Management Act will require farmers in some eastern counties of NC to
have a nutrient management plan that addresses all nutrients. This
plan only addresses Nitrogen.
APPA-
APPLI.
Acr � LQ sot, "14 PC
[QaP
RAr�
moor
UJI t 7%
B�
, �.
9G
I A LeA
g
6
9G,
I TO
SQ
•`� 6
IA LeA
SC
�
9�

WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own 'adequate
land. see required specification 2.)
PAGE 3
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW
PER AC
AC
USED
APPLIC
TIME
450
q 19
To
S6
N/A
50
9
,c4
1A
Le -A
SCa
N/A
so
so
TTAL 600
Indicates that this field is being overseeded (i.e. interplanted)
or winter annuals follow summer annuals.
* Acreage figures may exceed total acreage in fields due to
overseeding.
** lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables.I and 2 above:
CROP CODE
CROP
L-1VFTS
LBS N
PER UNIT
Btu
HYBRID BERMUDAGRASS-HAY
TONS
so

WASTE UTILIZATION PLAN PAGE 4
TOTALS FROM TABLES 1 AND 2
TABLE 1
TALE 2
TOTAL
AMOUNT 01
0
9
.00
MEZ
12�
3585
N PRODUCED 2964
3565
* * * BA __'NCE, - 621
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffers, filter strips,along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will'be, more than
the acres shown in the.tables.
NOTE: The Waste Utilization Plan must contain 'provisions for periodic
land application of sludge at agronomic rates. The sludge will be
nutrient rich and will require precautionary measures to prevent
over application of nutrients or other elements. Your production
facility will produce approximately 501.6 pounds of plant
available nitrogen (PAN) per year in the sludge that will need to be
removed on a periodic basis. This figure is PAN when broadcasting
the sludge. Please be aware that additional acres of lard, as well
special equipment, may be needed when you, remove this sludge -
See attached map showing the fields to be used for the utilization of
waste water.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of -
the soil at the time of irrigation such that runoff or ponding occurs.
This rate is limited by initial soil moisture content, soil structure,
soil texture, water droplet size, and organic solids_ The application
amount should not exceed the available water holding capacity of the
soil at the time of irrigation nor should the plant available nitrogen
applied exceed the Nitrogen needs of the crop.
Your -facility is designed for 180 days of temporary storage
and the temporary storage must be removed on the average of once every
6 months. In no instance should the volume of waste being stored in
your structure be within 1 feet of the top of the dike.

Vol
WASTE U'T'ILIZATION PLAN
PAGE 5
If surface irrigation is the method of land application for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables 1 and 2. Failure to apply the recommended rates and
amounts of Nitrogen shown in the tables may. make this plan invalid.
Call your technical specialist after you receive the waste analysis report
for assistance in determining the amount of wast` per acre and the proper
application rate prior to applying the waste. - -
NARRATIVE OF OPERATION:
a5: 3�a� Sours• ne p�era i o n IS
Fe -'tae r
raduce� a9�
QfrnOur� 1 � I r
CL"ke - +0 cbmp 1�� r '�
i (tGtae�(A4C�.
4
t`G�tOW
+ o
--T
�A
�'@L
�t-
TO
r,C�SeRk
nragf
0.rll\-
a5: 3�a� Sours• ne p�era i o n IS
Fe -'tae r
raduce� a9�
QfrnOur� 1 � I r
CL"ke - +0 cbmp 1�� r '�
i (tGtae�(A4C�.
4

WASTE UTILIZATION PLAN PAGE 6
Plans and specifications
1. Ani -mal waste shall not reach surface waters of the state by runoff,
drift, manmade conveyances, direct application, or direct discharge
during operation or land application. Any discharge of waste which
reaches surface water is prohibited. Illegal discharges are subject
to assessment of civil penalties_ of $10,000 per dayy by the Division
of Environmental Management for every day the discharg& continues.
2. The Field Office must have documentation in the design folder that
the producer either owns or has long term access to adequate
land to properly dispose of waste. If the producer -does not own
adequate land to properly dispose of waste, he shall provide NRCS
with a copy of a written agreement with a landowner who is within
a reasonable proximity, allowing him/her the use of the land for
waste application for the life expectancy of the' production
facility. It is the responsibility of the owner of the facility
to secure an update of--the-waste Utilization Plan when there is
a change in the operation, increase a -n the number of animals,
method of utilization, or available land.
3_ Animal waste shall be applied to meet, but not exceed, the
Nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climate conditions, and
level of management, unless there are regulations that
restrict the rate of application for other-hutrients.
g. Animal waste may be applied to land that has a Resource
Management System (RMS) or an Alternative Conservation System
(ACS). If an ACS is used the soil .loss shall be no greater
than 10 tons per acre per year and appropriate filter strips
will be used where runoff leaves the field. These filter
strips will be in addition to 'Buffers" required by DEM.
(See FOTG Standard 393 - Filter Strips and Standard 390
Interim Riparian Forest Buffers).
5. Odors can be reduced by injecting the waste or disking after
waste application. waste should not be applied when the
wind is blowing.
6. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally
tilled cropland. when applied to conservation tilled crops
or grassland, the waste may be broadcast provided the
application does not occur during a season prone to
flooding. (Sep "Weather and Climate in North Carolina" in
the NRCS Technical Reference - Environment __le for guidance.
7_ Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or
to surface waters and in a method which does not Cause drift
from the site during application_ No ponding should occur
in order to control conditions conducive to odor or flies
and to provide uniformity of application.
8. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in
such a manner that no more than 20 to 25 -percent cf the.leaf
area is covered.

WASTE UTILIZATION PLAN PAGE 7
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching_ Waste nutrient loading rates on these soils
should be held to a minimum and a suitable winter cover
crop planted to take'up released nutrients. Waste shall'
not be applied more than 30 days prior to planting of a
crop on bare soil.
11. Animal waste shall not be applied closer than 25 feet to
surface water. This distance may be reduced for waters that
are not perennial provided adequate vegetative filter strips
are present. (See Standard 393 - Filter St,ips)-
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those -owned by the landowndr.
14. waste shall be applied in a manner not to reach other
property and public right -of ways.
15. Animal.waste shall not be discharged into surface waters,
drainageways, or wetlands by discharge or by over -spraying.
Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site
by a "technical specialist". Animal waste should not be
applied on grassed waterways that discharge into water'
courses, except when applied at agronomic rates and the
application causes no runoff or drift from the site.
18. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into
the animal waste management system.
17. Lagoons and other uncovered waste contair_ment structures
must maintain a maximum operating level to provide adequate
storage for a 25 -year, 24-hour storm event in addition to -
one (I) foot mandatory freeboard.
18. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments,
berms, pipe naris, etc.) . If needed, special vegetation
shall be provided for these areas and shall be fenced, as
necessary, to protect the vegetation. vegetation such as
trees, shrubs, and other woody species, etc. are .limited to
areas where considered appropriate. Lagoon areas should be
kept mowed and accessible. Lagoon berms and structures
should be inspected regularly for evidence of erosion, leakage
or discharge.
r
19_ If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and imple-
menting a "closure plan" which will eliminate the possibility
of an illegal discharge, pollution.and erosion.
20. waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept
on site.

WASTE UTILIZATION PLAIN PAGE 8
NAME OF FARIM: Craig Collins
OWNER / MANAGER AGREEMENT
I (we) understand and will follow and implement the specifications
-and the operation and maintenance procedures established in the ap-
proved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of the
waste treatment and/or storage system or construction of new
facilities will require a new utilization plan and a new certification
to be submitted to DEM before the new animals are stocked.
I (we) understand that I must own or have access to equipment,
primarily irrigation equipment, to land apply the animal waste
described in this waste utilization plan. This equipment must be
available at the appropri-afte'-pump ing time such that no discharge
occurs from the lagoon in a 25 -year 1 -day storm: event. I also cer-
t3xy that the waste will be applied on the land according to this
plan at the appropriate times and at rates that no runoff occurs.
NAME OF FACILITY OWNER: aig Collins
SIGNATURE: DATE : S-,
NAM= OF MA�vAGE_ (if different from owner}
please print
SIGNATURE:
DATE:
NAME
OF TECHNICAL SPECIALIST: Wilson Spencer
AFFILIATION: NRCS
ADDRESS (AGENCY): 84 County Complex Rd.
S IGNATUr_E :
ATE.

.r•'"„' r'TI:'
CIA sit
t ' I �j
i{r, j`k•' 'All i yy 5'\13t�{'ij$n� Aa•l,T p{4"`yr ys/
- . -- aT`{rr.�:iti'.:7�1
! ]_s,.vr,'• �•}�-fC� �,;r Jr..r .^;'�,�. S�'r `F1S Pr"F!`'9r;r,F,'i�. T" Y+�
\y i. (, ,] . r4 -. r,�r_._ •t��'y y M•�'K .7r �����r "'. .:�t rrr. t'�
.1" ',,' -kr.' •' '!• ' 6y% s'; grw• '';i. tr,`��-'"{al'
.'�.; ",� •,':�'('�• �r•�'1��,�.'.' . ,
' ', t �`+'s.r+:.,,.itr't, :•'�u,AlI �T�"'y�i�F}�iif►,';F.,y`���,��1.i•?i•(+�,Syi .�{° op�•., ',r'i!r+a.! '• �rrk iI�y�/-t+�lj-��,,`n,'y: 'i`+ti1'K S3 .#.i`trZ�r�F, .p�i.','.#: tyrs.;f''��Vf,llSr,j" .wRv L�n,
,ti;r!■•r7ai{F11yni+y�`}]•tiJ-`i{./yit
'�*A."y.r��ri,{r.3J' .,.'��,`rLrI ii,!.■;
"r
f�
" ''' t.']•_k' M}�..Ll. !t "�4�Sa �: ..'�r. n�'t��tt��xi»tij�,ti',s+ +�
j .01
r_0
RIO,"
,1.; 1.•S'_��y`t.^7 �r••�w •�1 �,tiijlr fi'Li', 'l,�
Ytr•,.'r
.i` •r} .• ',.' '� r!:,1' ,•.•; R^ �.•}!fir -a! 1
., a' yf•+ ]�: r �,i,`{it��(. r T7 #��F J��'�St �`I��
: ►'1 , ,t. '"T',, , b e ,L k s
-r I r -s. is I,�' �',' t"+i •''r } s•tl�,
• ,;f',n• a+'.+'N�,,;:1rn: :•'iY�Xi'k !'I"i ry '••7Ti
• aNY.,lJ.,J+Lrtt�, ,r w f., 1,•,r� A
417
�. •�!'.'�ilr"`Il[l• ,'r'•; ;;t.:.:, py.�+
' .i .YFMI.Fq Ky'1,r''r yi
3,P �'f .A.,K' `I•��J-.�Y rFf ,fit',}•{,r yti '�%
NOT, 1. .irf:�� �'4i +' :I.1 .':' }�i:(•f. •,�r�� 1r;,«..:i.'�' •'I' ti t'' ;�';: '}` v•�._�.r
ra ./a4\,'� l.��afill,�� t d,1' !i']. is j{_••. ti` `!,`'t +i ,i, •'rr ,,. S+
j Ii�•.i p= y.,. \(., - fed. y.• S .t'�!I�; 1I , • rf,'';''r i wr.�-,i.+s"�1.,•Y=�f6�:i ire
�jy�'iii � y - i Jb !'ri'•}('
No.d4 i'
tity � ���+. t _ • , .. , r,` .: y. . i .Y�L jy t,y I if__` I.f •!•.r• -
�-j.Y 1 � y�� .t'1' :;' 'l' � _ � a. •• ':,.. �i=a-'1!y h_, _�-_' -•cr _� -:
, i r� ,1• +i; , r � r ,� 5, I
i' r s^ a 's1yh r: i ,• r rt' '•i 5'1'':'ySi!• '''T' , ' '
yi-�1��!:ii, :,,�.'. f1;':_+•�h�:l;'..e�j�,t•�;, {•,' \ � rr.-. ,r }�eJ,•{'�3f,•,�a�� .��„ .. ,
7jer� :L{J,'Ir, 1 r :Air ]'� 5' r�'�+i "• +� 1 r"� rid �1
'��rdrf�h�y'(,�'F+,}il!!��i�j,�,yf ;ice, e!!'�`�1�L�'_,I�'i'La!k!� �r.t t�'r �Ay ��i : • �r' 'r {
"r]rh��' • •��, r.S ;!�% , A r . ' * r�r t ,r r yk,'i` : - ;
.iF; Kati rY�a,�{i.r'ti!'�y,� ,J,�?� rrrISSS•� h�r , • I�. l yo �, � i � � f i 4 ,' -
�Z� i£io y 1 :i j{•�iL +1,, �•'ef ,li•4.r,�'z ::•Ls i ^ ^ F��'! :.. y 1 11 a
,t"'.•• ,;� !"�' +:,i!?�"�"rGs.�yl��;r•s;i�•`.i;^.i,,�,:*,'';��.;:•{':r?� ii�r a
G�'
�!iilit���t'��'y�r,.+••'•�p,- '
\tt,
rCl-
��F.'..•�.�.�r�C' .'�p��"�'.?.t .3r��'l��n'i i'! ' i '��, � ^.`'i ''�•Ary'�'S�•+" � ,:+` '
R :: qq}} r r 1¢ 1 •C
,�•::i� �i�� p�!•t �{'i�9� LIl1•'Y� '� Ls .3r, ~r :•]. �"1:; ��r;t�,� i(��' � _
IN
NF
,r,�;�,ly.s`t�;`, - - �l� '>'��7'• '.$ `}l•�i j i! w.
sokF.
�F rl- r . � 1 "� Y.S•.
_'•�.`. %�.�+nl y: ,iCJr�• -�fi�1V.!.. .r:,:.,,:' ; . .t' " ,1'r-• "�+
'r fid 1 , :' i 1 , � E ' �.d ' •�ii-.r. :;.r
,tekid . at. _y'a'• �Fy.1l '!�'• .1^ - .r'•: '�•-..:1�#:('• '.� - -
le.".�•y., rnr. :4� " w::�n °'y i'-:,'� •1. _•lJ., , • r-••, A 'j :`{-.ar{ •�.
',i�•Z:i'J�r• •t' 4e^�- :. .�'
T�' :�i ., ii -�•�f' �.' t'ti','r � S,s6''� Rt��,� :hdt:rr�;:, i.;-+' - �'rr. 'Yi••a-�°�"i K: -- ''-�., W.,Y'�'!4' i�.
Fik �•,` .:k':.y ••kL �iiR: i :,, �, tl'T. '1 �'r ,+,.! } -, ..' 'I •: , ,,tir - �'+f.:. A{ .�-' -
It
r.,, .pkv pl'C .:,- ` •�- .1,1 '4. L7yr+� -IrF+ '�r r' '?`' `•n., •�' 'I. •r ., .,J.`r., .,, ,
w,�;, i''1�` yy''))?!'-. .h �f •i .l`'i'f+�k''i'•A h1i r. a !(- ,�
AWN
,!:•ili „
'•�k ,►L+U'Fi'., y tr'i ..r1''Li�� '' If �.
�•�.i, /i 1• �x.:r.F ]. + ,a:`I,(: ,?�•�'y�.t{5'/'r vJ •1
•rr?r ' i 'h]"S j Vit. i?'' r h,t ;.� 1`r°''. 1„ :''? r•.f}.'�� • ...i{.•5i 'i " .�:� . 1:.i.'r
,3' i.- ; �';'��• .} •+11'y* +i,'r •''r' • � ;:-4 rr;.1 •ly'�:•'.,
.,>, .+:� s h r% fwr, 1 , t!•i�: i:'. :r'
t�Y' 3' .vr '1. AJ•.'�.� :�r
¢yhrr♦ '•'l�l.;t !�yi ,+, .y! a Fi:.SpyFfj rJ 5 :,+ ,'r .•U:,' s'a;::l• ,w,�,,.s, :;1 i',r.� r-. ft-
r,+,��y°ri�i'Ps:, �:. r `�Sa(!`r.1�5. gL,., it �r :'i.�,;,s i,:. '•r•: r.�- � ja•
Tip, ;Ih{. ,f. pi r 1. .'►�'a ','. :�lJ• r.,�i•�� �-.•!•,'�.'+• A,
I-�y �.+i�r{�r},i:':' •',y' A('+ 'tSp 'dh`1�,, 1��i 7:. •F•- �iyc °� h' 1r`�. :7 �+�-Y�''%-Yf!6 J,�,.,' .�':rr•'..rn•:
l}rjj '!' ,'. ; : 1 "F,. t}} `r J', s•'i. •.j . + Y ..ri �, ,:e,i•i}.. .i , y : . ±i
f. r r'� : � � I •,der :if:,r.
G"J r• n:. 7ti':- f ..i `' '•r�. :�•. :.i'-rJ%.:: ,i!: J, �r �.
x .f;i..i`' , r'.rs�:R:ui ��,ri1s,•.rlff, •t'r, �' .rhe ,.y ��„i' :,k.� w �:ii•�'�Sr!'•� .t.n.,::.ri;�a�•%. . .
f`�..f .,, .S+ 'Q'ir,. '!.+�':e, .S�r .l Til,r.a J -'i .�,}p( +Z r;t•
+r '�',:j♦a�l=3i'�l.r•{ �fi•�, I, r; i:{{;'�i•, •ri•''5'• '''•i•���.^�Y. •+.��.i' •r,7i -
�,. .�,i�=�i+1s"�tf�":+, a.�j .� �r1 :.j •r •r�'• •i r „f may' `' r r �„-y S Y}, 4r .r ,
� r�};}•�#`T {:fw�{1"��:�liiis�,',�,�'l� rMn• '�,ti�' _`v. - •h-«�l }f �n.'td��r �:� '�..:;i{i� s"
,yr �{r'Ft++'r.� '1 �,i.c•,y: •.,: '.f,..,G.••� '*�.��°?'iSiJ '�r
r-1.-s�., r? -:1".. ' i.�.. �r „jr'�.,yi.r.. ;t:, :�.,, • ? ' _ - ... 'i•{- .1�:.re'''`...}'r��t- _i • . r��'
.'rn•r • .I •r�.yarr• r,y } •11t.r •1'rd✓i a; y,-. ::.{!,u;,.t':. .. �:Jc:. ': «Y:':' z�3 �".:.y 7%''=
:-lr�;�': ..i,.rirlaE,. _�+,r '°. ,:i?' 'y2�►ii:F`.rr.�;!� ti. -_ :�� r•S�r]`:lai�'ir.- ,�,:�'��':;"•��-,
1,�.:�11i �}�{,y���;!y`. ,1�J +]'��il:•;�'r 1 i`I,f�'ri' ;�•y'• .r.: ��r y s• !:}' .r• s�.P...�rl.',�� :'.�kl� �.
_T r:.�IIFi ,�, .-rll:-�'.F:`. 1'J .:'L'. r�jJ!��, .r.:•... .L :�r-
�'�J _ 1` �f.,t•+'�P• •[ r '•i,. .,{r;'' j . ^ �;•.y '�� •"�'•' ': ^ii'�'!•W'�,'. ;^i�•° ':i - is - ..-
J • r::: (; }} :< rr
s.'{, lS•i%l:�at,l,�-.r'i,�;4S Yp ,rj: ,` ;��!.'�T tr_r :t�.',y 4L•;,Sf•' -.N: .i �t
i�� s•;��.••+•. _4 A fY,. r�
I • yr�'t;�l'`+''' i I,l; ,�'. .:�?. _ =i. .v1� ti. - ''.i�;•S: _,y:�,-an' .
j � t'''�,t I'F� .. UIt ;.,..� �t •yt s',i .i •rte ' . �i- � E .
�{� (•� I •r T ' +s r i.e ' !� J�l`,a ,Y P -
•l ~�c ,y, .� '7p1. ,.,Fr Ay{I, •'t ,f .i�. , . _ .r •;
1.-.�; �,,,, ,�' ,.,.:',i+ �yi��'1rS'i.;'•k�ri',•-�i•,••. '1r�;1 � "3 .. rn r''
.iii'r ,�'.:r'�' �.i•; •`':t�'".71� .j.l.. j :'�ti;, .i'• .1'r�_: i s ''i: "t;: n�;
� '�''�'s�:]' .• w,s Irl 1�7 •:!J � ii.� '..
� •-, �s''•,1 l,yr � '�r r a,i's*i%,���FY r�: av � ••il ,L•_,++1. �.. y. 5, �y'f,�#;�<�J<►• �''�,: ;: ?•y
rt - .>• cl .±I� r �r7irr ��, }� �. � r P !F r:i � 6 .,�,' j • a i* ' S t ' U` {r'.. .1 ,
,(r { 4rtf 7 ! �.(1��r'r �L;r�kee►..tA¢f1��i' .'r`ir.,_w 1'.Fy"•rYYJ
Il..:I �r n.,�i'i�'G: :r'ii] .'"►,. .k r". ,I�ii,�,ErrsGr 'e..,� '+.p','�lr �,{v `#�d.,•lij'y���« '� ,fir
}.�y k�', i1c`��•^' ^F..'''';i r�A r. ,,,j,,j' Vii• y�+
4'f 2i '�y �, :Yj ,L, J*'•G{ R1'i �'•' + �r4 fl � TIyY�`y+Ar Ar .]`���'t ' ;i �`�`;§�`.
�3hr•�]� 'f h r'r ;!'i•, •Ta ;t"�• ,F `y�r i` •1��,�r-,',;t'-,'7.f;;'r :+r'+.• '' R '1` �
tit�l .. , ,a. I : I;^f:: _. ... .:,f..{��._:.i:.;Y.. '�...r.r.i. �oJ±�.1:i.L. a;.t.r..'t'r ti.• a:r .. -

5°
��
5
p-
-
, I, -- rt-1-�-t+
O
}
iitill
fit
it ,
-N I
Itt
_t -tit
�
I 1 , , --•I -�-� , , ' , , t ,-'t�_.j "'Y.ry' ,-ice__
Itil
-=-rte,.-•--•-•----T--.._._-..__ ___-� .--..-. �._._-. -_. _ __ - V'-�"'._._---.-..-} ._-_'.__-�_ 7
71
it -------------

SAMPSON COUNTY
EMERGENCY ACTION PLAN
DIVISION OF WATER QUALITY (DWQ) 910-486-1541
EMERGENCY MANAGEMENT SERVICES (EMS) 910-592-8996
SOIL & WATER CdNSERVATION DISTRICT (SWCD) 910-592-7963
NATURAE. RESOURCES CONSERVATION SERVICE (NRCS) 910-592--7963
COOPERATIVE EXTENSION SERVICE (CES) 910-592-7161
This plan will be implemented in the event that wastes from your
operation are leaking, overflowing, or running off the site. You should
NOT wait until wastes reach surface waters or leave your property to
consider that you have a problem. You should make every effort to
ensure that this does not happen. This plan should be posted in an
accessible location for all employees at the .facility. The following
are some action items you should take.
1. Stop the release of wastes. Depending on the situation, this may
or may not be possible. Suggested responses to problems are
listed below:
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam, any
permanent alteration of the dam should be approved by a
qualified technical specialist.
b. Pump wastes to field at an acceptable rate.
c. Stop all additional flow to the lagoon -hold waste in the
house if possible.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
S. Runoff from waste application field -action include:
a. Immediately stop waste application.
b. Create a temporary diversion or berm to contain the
waste.
c. Incorporate waste to reduce further runoff.
d. Evaluate and eliminate the reason(s) that caused the
runoff.
e. Evaluate the application rates for the fields where
runoff occurred.
C. Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle (flushing system) pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
e. Repair all leaks prior to restarting pumps.
D. Leakage from flush system, houses, solids separators -actions
include:
a. Stop recycle (flushing system) pump.
b. Stop irrigation pump.
c. Make sure no siphon effect has been created.
d. Stop all flows in the house, flush systems, or solid
separators.
e. Repair all leaks prior to restarting pumps.

E. Leakage from base or sidewall of lagoon. Often this is seepage
a's opposed to flowing leaks -possible action:
a. Dig a small sump or ditch to catch all seepage, put in a
submersible pump, and pump back into lagoon.
b. If holes are caused by burrowing animals, trap or remove
animals and fill holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side
walls and the lagoon bottom as soon as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what
duration?
c. Any damage noted, such as employee injury, fish kills, or
property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface
waters?
f. Could a future rain event cause the spill to reach
surface waters?
g. Are potable water wells in danger (either on or off of
the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours, call your DWO (Division of
Water Quality) regional office, at 910-4B6-1541, after
hours, emergency number:919-733-3942. Your phone call
should include: YOUR NAME, FACILITY, TELEPHONE NUMBER,
THE DETAILS OF THE INCIDENT FROM ITEM #2 ABOVE, THE
EXACT LOCATION OF THE FACILITY, AND THE LOCATION OR
DIRECTION OF MOVEMENT OF THE SPILL, WEATHER AND WIND
CONDITIONS. THE CORRECTIVE MEASURES THAT HAVE BEEN UNDER
TAKEN, AND THE SERIOUSNESS OF THE SITUATION.
b. If spill leaves property or enters surface waters, call
local (EMS) Emergency Management Services at
910-592-8996. 1
c. Instruct EMS to contact local Health Department.
d. Contact local SAMPSON Soil and Water Conservation
District (SWCD), Natural Resources Conservation Service
(NRCS) office at 910-592-7963 and Cooperative Extension
Service (CES) at 910-592-7161 for advice/technical
assistance.
4. If none of the above works call 911 or the sheriffs Department
and explain your problem to them and ask that person to contact
the proper agencies for you.

Contact the contractor of Your choice to begirt repair of the
problem to minimize off-site damage.
a. Contractors Name :-r�Y YJEKGS
b. Contractors Address: JTj9KB7y fl/C-
c. Contractors Phone: 914- 592,- 5765_
6. Contact the technical specialist who certified the lagoon (NPCS,
Consulting Engineer, etc.)
a. Name: 61'ew J cor7'ToAl
b. Phone: 0- S9Z- 2 Z 49
7. Implement procedures as advised by DWO and technical assistance
agencies to rectify the damage, repair the system, and reassess
the waste management plan to keep problems with release of wastes
from happening again.
B. If you are a contract swine grower associated witty a swine
company integrator, contact the company representative at
1-910-592-5771
A

Insect Control Checklist for Animal Operations
Source Cause BMPs to Control Insects Site Specific Practices
uid
Flush Gutters • Accumulation of solids
r;V— Flush system is designed and operated
sufficiently to remove accumulated solids from
gutters as designed.
Remove bridging of accumulated solids at
discharge
Lagoons and Pits Crusted Solids
21 Maintain lagoons, settling basins and pits where
pest breeding is apparent to minimize the
crusting of solids to a depth of no more than 6 -
8 inches over more than 30% of surface.
Excessive Vegetative • Decaying vegetation
Maintain vegetative control along banks of '•
Growth
lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along water's edge on impoundment's perimeter.
Dry
Feeders • Feed Spillage A Design, operate and maintain feed systems (e.g.,
bunkers and troughs) to minimize the
accumulation of decaying wastage.
Cleanup spillage on a routine basis (e.g., 7 - 10
day interval during summer; 15-30 day interval
during winter).
Feed Storage • Accumulations of feed residues 1% Reduce moisture accumulation within and
around immediate perimeter of feed storage
areas by insuring drainage away from site
and/or providing adequate containment (e.g.,
covered bin for brewer's grain and similar high
moisture grain products).
inspect for and remove or break up accumulated
solids in filter strips around feed storage as
needed.
AM IC - November 11, 1996, Page 1

Swine Farm Waste Management Odor Control Checklist
Source Cause BMPs to Minimize Odor Site Specific practices
Farmstead • Swine production 0 Vegetative or wooded buffers;
Recommended best management practices;
® Good judgment and common sense
Animal body surfaces • Dirty manure -covered animals Dry floors
Floor surfaces • - Wet manure -covered floors M Slotted floors;
7 Waterers located over slotted floors;
© Feeders at high end of solid floors;
A/ Scrape manure buildup from floors;
❑ Underfloor ventilation for drying
Manure collection pits • Urine; D Frequent manure removal by flush, pit recharge, '. .
• Partial microbial decomposition or scrape;
❑ Underfloor ventilation
Ventilation exhaust fans • Volatile gases;. Fan maintenance;
Dust ®�fficicnt air movement
Indoor surfaces • Dust IY Washdown between groups of animals;
© Beed additives;
VFeedceder covers;
delivery downspout extenders to feeder
covers
Flush tanks • Agitation of recycled lagoon ❑ Flush tank covers;
liquid while tanks are filling W Extend fill lines to near bottom of tanks with
anti -siphon vents
Flush alleys • Agitation during wastewater Iso Underfloor flush with underfloor ventilation
conveyance
Pit recharge points • Agitation of recycled lagoon 0 Extend recharge lutes to near bouom ol'pits
liquid. while pits are filling with anti -siphon vents
Lift stations • Agitation during sump tank O Sunup tank covers
filling and drawdown
Outside drain collection • Agitation during wastewater ❑ Box covers
or junction boxes. conveyance
AMOC - November 11, 1446, Page 3

ree
use
to Minimize Odor
Practices
End of drainpipes at + Agitation during wastewater Extend discharge point of pipes underneath
lagoon conveyance lagoon liquid level
Lagoon surfaces • Volatile gas emissions; Proper lagoon liquid capacity;
• Biological mixing; �J Correct lagoon startup procedures;
• Agitation t!] Minimum surface area -to -volume ratio;
l�1
Minimum agitation when,pumping;
7® Mechanical aeration;
❑,,,I'roven biological additives
Irrigation sprinkler • High pressure agitation; m Irrigate on dry days with little or no wind;
nozzles • Wind drift V., Minitnutn recommended operating pressure;
Pump intake near lagoon liquid surface;
❑ Pump from second -stage lagoon
Storage tank or basin • Partial microbial decomposition; ❑ Bottom or midlevel loading;
surface • Mixing while filling; ❑ 'Tank covers;
• Agitation when emptying ❑ Basin surface mats of solids;
❑ f Proven biological additives or oxidants
Dead animals + Carcass decomposition ® Proper disposition of carcasses
Dead animal disposal + Carcass decomposition 0 Complete covering of carcasses in burial pits;
pits ❑ Proper location/constructioa of disposal pits
Incinerators • Incomplete combustion O Secondary stack burners
AMOC - November It, 1446, Page 4 •
❑
Proven biological additives or oxidants
Settling basin surface •
Partial microbial decomposition;
❑
Extend drainpipe outlets underneath liquid
•
Mixing while tilling;
level;
•
Agitation when emptying
C1
Remove settled solids regularly
Manure, slurry or sludge •
Agitation when spreadit►g;
❑
Soil injection of slurry/sludges;
spreader outlets •
Volatile gas emissions
❑
Wash residual manure from spreader after use;
0
Proven biological additives or oxidants
Uncovered manure, •
Volatile gas emissions white
❑
Soil injection of slurry/sludges
slurry or sludge on field
drying
❑
Soil incorporation within 48 firs.;
surfaces
O
Spread in titin uniform layers for rapid drying;
❑ f Proven biological additives or oxidants
Dead animals + Carcass decomposition ® Proper disposition of carcasses
Dead animal disposal + Carcass decomposition 0 Complete covering of carcasses in burial pits;
pits ❑ Proper location/constructioa of disposal pits
Incinerators • Incomplete combustion O Secondary stack burners
AMOC - November It, 1446, Page 4 •

Source Cause I BMi's to Minimize Odor Site Specific Practices
Standing water around • improper drainage; IV Grade and landscape such that water drains
,facilities . Microbial decomposition of away Goin facilities
organic matter
Manure tracked onto • Poorly maintained access roads 10 Farm access road maintenance
public roads from farm
access
Additional Information : Available From :
Swine Manure Management ; 020011ulc/BMP Packet NCSU, County Extension Center
Swine Production Farm Potential Odor Sources and Remedies ; EBAE Fact Sheet NCSU - BAE
Swine Production Facility Manure Management: Pit Rccllarbe - Lagoon Treatment; EBAE 128-88 NCSU - BAE
Swine Production Facility Manure Management: Underfloor Flush - Lagoon Treatment; EHAE 129-88 NCSU - BAE
Lagoon Design and Management for Livestock Manure Treatment and Storage ; EBAE 103-83 NCSU - BAE
Calibration of Manure and Wastewater Application Equipment ; EBAE fact Sliect NCSU - BAE
ControlUng Odors from Swine Buildings; Pill -33 NCSU - Swine Extension
Environmental Assurance Program ; NPPC Manual NC Park Producers Assoc
Options for Managing Odor; a report from the Swine Odor Task Force NCSU Agri Communications
Nuisance Concerns in Animal Manure Management: Odors and Flies; PRO107, 1995 Conference Proceedings Florida Cooperative Extension
AMOC November 11, 1996, Page 5

Mortality Management Methods
(check which method(s) are being implemented)
❑ Burial three feet beneath the surface of the ground within 74 hours after
knowledge of the death. The burial must be at least 300 feet from any flowing
stream or public body of water.
Rendering at a rendering plant Iicensed under G.S. 106-168.7
C! Complete incineration
❑ In the case of dead poultry only, placing, in a disposal pit of a size and design
approved by the Department of Agriculture
❑ Any method which in the professional opinion of the State -Veterinarian would
make possible the salvage of part of a dead animal's value without endangering
human or animal health. (Written approval of the State Veterinarian must be
attached)
December 18, 1996

Lagoon & Storage Desi, ncnDDa_ta
Type, number, and sizes of livestock:_
Total No. for design
354_. sows x 385 bs = 140.140 lbs
_ r _ boars x is5 lbs = lbs
490 pigs x 90 lbs = lbs
ESQ, pigs x 35-- i bs = ?6, 50 lbs
504 igs X 8 = 4,032
or: Total ibs for design 271,762 IDS.
USDA -SCS
Raleigh, N. C.
:•
Rev. 2/82 -
-
:': ;: • - ::, .. ' - r:.. • :: - :; - y:,�� ::�,+?"r,
ANIMAL WASTE MANAGEMENT SYSTEM
Engineering Design -Work
. Field Office
Clinton Design by Howard Hobson pate 7-30-85
Owner's ?dame -Craig
Collins Phone -44#44454 5.3 Z— q -S49
Location Approx. l mile NW of Kerr on SR 1121
-attach watershed location sketch)
Population (est) within 1/4 mi. 4 No. of inhabited houses.within
.1/4. mi. .• -.o
-Distance to nearest -.inhabited house other than
operator's APRrox,
1 mile
Type of livestock
Swine Type of, operation.(check one)
Farrow to finish
Farrow to feeder pig__2L__ Finish Other
I
Type of confinement facility (flush, pit, number of houses, dimension. of
houses., etc.) 4
Type of waste. treatment: Anaerobic lagoon & holding pond Anaerobic
t
lagoon with holding volume. x holding pond pit or tank'
s
other
Method of handling
waste when design capacity is reached (i.e., pump & irri.gation,
honeywagon, etc.)
irrigation -
Lagoon & Storage Desi, ncnDDa_ta
Type, number, and sizes of livestock:_
Total No. for design
354_. sows x 385 bs = 140.140 lbs
_ r _ boars x is5 lbs = lbs
490 pigs x 90 lbs = lbs
ESQ, pigs x 35-- i bs = ?6, 50 lbs
504 igs X 8 = 4,032
or: Total ibs for design 271,762 IDS.

I.%
9. Total capacity needed for holding pond (add Ps 3, 4, 5, 6, 7, & 8)
0 cu. ft.
10. Total capacity needed for treatment lagoon (add #'s 1 & 9 when treatment
lagoon & holding pond are one component) = 315.583 cu. ft.
Planned Capacity for Treatment Lagoon
ft. x -ft. 6 ft. w/ 3 1 "Ss =
avg. length avg. wi th - avg, ept
cu. ft.
Planned Capacity for bolding Pond
_ ft. x � ft. x ft. w/ ss =
avg. lengtfi avg. w t avg. depth
0 cu. ft.
Design for Disposal -Area_
Annual nitrogen production in fresh waste =
sows N/SOW
364kx 97 lbs MgVt. x 365 days = �4�4RR lbs. N
Assume 75 % N loss during anaerobic lagoon treatment, storage & land application.
Estimated N available for crop 33,488 lbs x_Z% = 8372 lbs.
Type of vegetation or crop to be grown at the disposal site
Timing and rate of -application 1 inch/hour. _
Estimated acres needed for effluent disposal
Coastal: 364 sows x .04ac/sow = 15 ac.
Corn:. 364 sowsox •13.ac/sow = 40 ac.
Fescue: 364 sows °x a06ac/sow = 22 ac.

OPERATION AND MAINTENANCE PLAN
y This lagoon is designed for waste treatment with minimum odor control. The
time required for the planned fluid level to be reached may vary due to soil
conditions, flushing operations, and the amount of fresh water added to the
system.
Land application of waste water is recognized as an acceptable method of dis-
posal. Methods of application include honey wagons (sprayer or injection) and
irrigation (center pivots guns, or travelers). Care needs tc be taken when
applying waste to prevent damage to crops or runoff from the field.
The following items are to be carried out:
1. Begin pump -out of the lagoon when fluid level is 1 foot below the _
outlet pipes.
2. Stop pump -out before fluid depth is less than 3 feet deep (this
prevents the loss of favorable bacteria).
3. It is strongly recommended that the treatment lagoon be precharged
to 'k its capacity to prevent excessive odors during startup. Pre -
charging reduces the concentration of the initial waste entering
the lagoon thereby reducing odors.
4. Keep vegetation on the embankment and areas adjacent to the lagoon
mowed.
5. Repair any eroded areas and establish in vegetation.
6. Recommend that a suitable fence be constructed around the lagoon
for safety purposes.
7. The Clean idater Act of 1977 prohibits the discharge of pollutants
into waters of the United States. The Department of Natural
Resources and Community Development (DNRCD) - Wastewater Management
Section has the responsibility for enforcing this law:
NOTE: An analysis of the waste water can be obtained at commercial
laboratories or at a fee of $3 per sample at:
N.C. Department of Agriculture Plant Analysis Lab
Agronomic Division
Blue Ridge Road Center
Raleigh, N.C. 27611
Ph. [phone]

V f 13; (,a\
` ,animal Waste Management Pian Certification
(Please type or print all information that does not require a signature)
Existin yr New,.:or....:Ex ncled "0'6­6:_sclrcie ones ` f:
GeatrW tiformatiop:
Name of Farm:_C.0 " 0, N11\n�_
Owner(s) Name:_
Mailing Address:
ility No: 5
ne No: 94 69
Farm Location: Fourteen Digit Hydrologic Unit:_ j 0() 100
Latitude and Longitude: County: sor\
Please attach a copy of a county road trap with location identified and describe below (Be specific: road
m
naes, directions, milepost, etc.): f M` fie. H LQ r r S J
4neration Description:
Type of Swine No. of Animals Type of Poultry No. of Animals Type of Cattle
D Wean to Feeder _ Q Layer O Dairy
Feeder to Finish 0 Pullets D Beef
No. of Animals
D Farrow to Wean I 1
a-Varrow to Feeder i _ fetr�q,n on o r.Y. ur+T�f la SI bs,
D Farrow to Finish Otter Type of Livestock: Number of Animals:
Expar�ing V� VM•r
...
4 �} S h CK y j W.00,
C
42 - -.i } KS O
Previous Desrgn apartrX "> �O$Addir�vnal Des;gnapac..s. h
�.{z - /x�}/��t -, •� W� -' �''� a._.. F-.
laeSiglt Cr (ICt-1-� �^\ - ,.,.%„W +K )L. - � l�f hR } S �4.
_
ExisXsag msefExgaaduig Ope+on 4n xa hf Y� }}.'
F Regr3 n: 3c.26
k `� Date an whtrh app iri € strarsor 7
• /
Acreage Available for Application: l d Required Acreage:
Number of Lagoons 1 Storage Ponds Total Capacity: fa 3 Cubic Feet (ft3)
Are subsurface drains present on the farm: YES or (please circle one)
Owner 1 Manager Agreement
I (we) verify that all the above information is correct and will be updated upon changing. I (we) understand the operation and
maintenance procedures established in the approved animal waste management plan for the farm named above and will
implement these procedures. I (we) know that any expansion to the existing design capacity of the waste treatment and
storage system or construction of new facilities will require a new certification to be submitted to the Division of
Environmental Management before the new animals are stocked. I (we) understand that there must be no discharge of animal
waste from the storage or application system to"surface waters of the state either directly thrbugh a man-made conveyance or
from a storm event less severe than the ZS -year. 24-hour storm and there must not be run-off from the application of animal
waste. I (we) understand that run-off of pollutants from lounging and heavy use areas must be minimized using technical
standards developed by the 'Natural Resources Conservation Service. The approved plan will be filed at the farm and at the
office of the local Soil and Water Conservation District. i (we) know that any modification must be approved by a technical
specialist and submitted to the Soil and Water Cgnservation District prior to implementation. A change in land ownership
requires written notification to DEM or a new certification (if the approved plan is changed) within 60 days of a title &ansfer.
Name of Land caner.. Cc'a , e,\ `nS
Signature: Date: 9,
Mame of Manager .fferent from owner):
Signature:_ _ ('_ Date:
AWC -- ApriI 2A, 1996 1 FACII ITiES kSSESSMENT UNIT �� ��

1
Technical Specialist Certification
I. As a technical specialist designated by the North Carolina Soil and Water Conservation Commission
pursuant to ISA NCAC 6F .0005, 1 certify that the: animal waste management system for the farm
..name above has an animal waste mana'gement plan that meets or exceeds standards and specifications
of th6 Division of Environmental Management (DEM) as specified in 15A NCAC 2H.0217 and the
USDA -Natural Resources Conservation Service .(MRCS) and/or the: -North Carolina Soil -and Water
Conservation Commission pursuant to -I -5A NCAC 2H.0217 and 15A NCAC 6F..000I-.4005. The
following elements are included in the plan as applicable. - While each category designates a technical
specialist who may sign each certification (SD, SI, WUP,. RC, 1), the,: technical specialist should only
certify parts for which they are technically competent
--
II.... Certification
- II....Certification of Design i
Check the appropriate box •.
U )~x_dtinz facility without retrofit (SD or WLTP) _.. ..
Storage. volume is adequate for operation capacity; storage capability consistent with
waste utilization requirements.
New, expanded or retrofied facility (SD)
Animal waste storage and treatment structures; such as but not limited to collection systems,
lagoons and ponds, have been designed to meet or exceed the minimum standards and
specifications.
Name of Technical Specialist (Please Print):
Affiliation: C S
Address(Agency): y' eoun ' (a ,C Phone No.: iS9a —143
Signature: Date: I ,,
B) LgadAIication�61e (WUP)
The plan provides for minimum separations (buffers); adequate amount of land for waste
utilization; chosen crop is suitable for waste management; hydraulic and nutrient loading rates.
.. nE . \ .
Name of Technical Specialist (Please Print):
Address(Agency
C) Runoff Contro[5,fr
Check the appropriate box
" Facility without exterior lots (SD or WUP or RC)
This facility does not contain any exterior lots.
Phone No.: 59a— Qq&S
Date: le —
Q Facility with exterior Iots (RC)
Methods to minimize the run off of pollutants from lounging and heavy use areas have been
designed in accordance with technical standards developed by N'RCS.
Name of Technical Specialist (Please Print): C n e
S f1 n
Affiliat.
Address
-Signatu
hone No.:r9 f
later
AWC -- April 24, 1996 2

D} Anglication and HaLWling EguipMpnt
Check the appropriate box
B' Existing facili with existing waste application equijtnent (WUP or I)
-Animal waste application equipment specified in the plan has been either field calibrated or
evaluated in accordance with existing design charts and tables and is able to apply. waste as
necessary to accommodate the waste management plan: (existing application equipment can
cover the -area required by the plan at rates not to exceed either the specified hydraulic or
nutrient loading rates, a'schedule for tinning of applications has been established; required
buffers can be maintained and calibration and adjustment guidance are contained as part of the
plan).
C7Nc�w or ei�6ded facility: or existinz facility without z xi ��g waste application equipment (I)
Animal waste application equipment specified in the plan has been designed to apply waste as
j necessary to accommodate the' waste management plan; (proposed application equipment can
1111 cover the area required by the plan at'rates not to exceed either the specified hydraulic or
- --hiicrient loading rates; a schedule for dazing of applications has been established; required
buffers can be maintained; calibration and adjustment guidance are contained as part of the
.plan)..
of Technical Specialist (Please Print):
Name.
Affiliation: ?"O -S
Address(Agency): ! ,)u,4, -k eappluAd. Oh64n A/1 L , Phone No.: S ee -- 9163
SiLynature: -Date- 14— 1 7 `5� z
III. Certification of Installation
A) Collectio]3. Sto[agre. Treatment Installaton
New, expanded or retrofitted facility (SI)
Animal waste storage and treatment structures, such as but not limited to lagoons and ponds,
have been installed in accordance with the approved plan to meet or exceed the minimum
standards and specifications.
For existing facilities without retrofits, no certification is necessary.
Name of Technical Specialist (Please Print):
Affiliation:
Address(Agency): Phone No.:
Signature: Date:
AWC -- April 24, 1996 3

B) Land 62nlicatiou Site (WUP)
Check rhe appropriate box
R` The cropping system is in place on all land as specified in the animal waste'inanagementiplan.
0 Conditional Approval: all required Iand as specified in the plan is cleared for planting, -um
cropping sysfern.as specified in the waste utilization plan has not been established and the
owner has committed to establish the vegetation as specifed.in the plan by. _ _L
(month/day/year); the proposed cover crop is appropriate for compliance with the waste
utilization plan. -
❑i Also check this box if appropriate
if the cropping system as specified in the plan can not be established on -newly cleared
land within 30 days of this certification, the owner has committed to establish an interim
crop for erosion control;"
Name of Technical Specialist (Please Print)..t t5
Affiliation:
Address(AgencyN010 IClid ti CitiNtC, Phone No.: -'S;92 —0 1(-S
Signature: Date:__ JA
This following signature block is only Jtle used when the box for conditional approval in IIL B
above has been checked. _ =
I (we) certify that I (we) have committed to establish the cropping system as'specifted in my (our) waste
utilization plan, and if appropriate to establish the interim crop for erosion control, and will submit to
DENT a verification of completion from a Technical Specialist within 15 calendar days following the date
specified in the conditional certification. I (we) realize that failure to submit this verification is a
violation of the waste management plan and will subject me (us) to an enforcement action from DEM.
Name of Land Owner:
Signature: Date:
Name of Manager(if different from owner):
Signature: Date:
C) Run r!Dlg from Exterioris (RC)
Facility with exterior lots
Methods to minimize the run off of pollutants from lounging and heavy use areas have been
installed as specified in the pian.
For facilities without exterior lots, no certification is necessary.
Name of Technical Specialist (Please Print):
Affiliation:
Addmss(Agency): Phone No.:
Signature: Date:
AWC -- April 24. 1996 4

i
1
D) Aoolication and Handling Equipment Installation (WUP or I)
Check the appropriate block i
Animal waste application and dandling equipment specified in the plan is on site and ready
for use; calibration and adjustment materials have been provided to the owners and are
contained as part of the plan.
Cl Animal waste application and handling equipment specified in the plan has not been
installed but the owner has proposed leasing or third party application and has provided a
signed contract; equipment specified in the contract agrees with the requirements of the
plan; required buffers can', be maintained; calibration and adjustment guidance have been
provided to the owners anis are contained as part of the plan.
ZI Conditional approvalAnimal waste application and handling equipment specified in the
plan has been purchased and will be on site and installed by
(month/day/year); there is;adequate storage to hold the waste until the equipment is installed
and until the waste can be land applied in accordance.with the cropping system contained
in the plan; and calibration and adjustment guidance have been provided to the owners and
are contained as part of the plan.
Name of Technical Specialist (Please Print): (2, kE,_kson �Cc�er'
., — -
-LiTinanon:
Address(Agency): 1 un ( iC t Phone No.:
Signature:
Date:�1
The following signature block is Jy to be used when the box for conditional approval in III D
above has been checked.
I (we) certify that I (we) have committed to purchase the animal waste application and handling
equipment as specified in my (our) waste management plan and will submit to DEM a verification of
delivery and installation from a Technical Specialist within 15 calendar days following the date specified
in the conditional certification. I (we) realize that failure to submit this verification is a violation of the
waste management plan and will subject me (us) to an enforcement action from DEM.
Name of Land Owner:
Signature: Date:
Name of Manager(if different from owner):
Signature:
Date:
Please return the completed form to the Division of Environmental Management at the
following address:
Department of Environment, Health, and Natural Resources
Division Of Environmental Management
Water Quality Section, Compliance Group
P.O. Box 29535
r Raleigh, NC 27626-4535
Please also remember to submit a copy of this form along with the complete Animal Waste
Management Plan to the local Soil and Water Conservation District Office and to keep a copy in
your files with your Animal Waste Management Plan.
AWC -- April 24, 1996 5

. TECHNICAL SPECIALIST FOR ANIMAL WASTE MANAGEMENT CERTIFICATION
DESIGHATION CATEGORY
CODE
AREA OF AUTHORITY
Collection, Storage,
SU (desigp)
- lagoons, storage ponds, dry stacks, storage -structures,
and/or Treatment
Sl,linstallation)
•composters, pushoff'ramps, curbing and other similar
structures
Waste Utilization plait'
WUP
- deslqn and inotaliation (development and
implementation) of land application plans
including crop and acreages available:to meet nutrient
budget,,hydraulic and nutrient loading rates, placement
of application site buffers
- measurement of existing storage volume
,•'., ' ,;
-
-Confirmation of existence and compatibility.of land
application equipment with waste utilization plan
-.c_rtification of cropping systems
-
- confirmation of absence of exterior lots
- confirmation of sludge and effluent removal and
application at agronomic rates for lagoon closure
Runoff ControlsRC
- design and installation of filter strips, grass
channels, and related bmps used to reduce ,runoff from
exterior lots (primarily dairy operations)
irrigation Equipment
I
- design and installation of irrigation systems to
include pipe size, pump horsepower, nozzle size, system
layout, thrust blocks, etc. and operation plan to meet
briteria of Waste Utilization plan (hours per set, etc.)
Technical Specialists are designated by the.Soil and Water Conservation Commission pursuant to 15A NCAC 66.0005.
Technical Specialists should only certify parts of a plan for which they are technically competent.

LANDING STRI{
Kk4KICI AUXILIARY MELD
0303000
I
SAMPSON COUNTY
NORTH CAROLINA
""omw sy TME
NORTH CAROLINA DEPARTMENT OF TRANSPORTATION
DIVISION OF HIGHWAYS — GIS UNIT
IN COOMUTKM w"H TK
U.S.DEPARTMENT OF TRANSPORTATION
• FEDERAL HIGHWAY ADMINISTRATION
kza::
2 3 4 MILES
SCALE FOR FWAXr-EMENn
lom pow "o coo Tl stllw

I
ANIMAL WASTE UTILIZATION PLAN
Producer: CRAIG COLLINS
Location: 202 WEST ARROWHEAD DR.
CLINTON NC 28382
Telephone: [phone]
Type Operation: Existing Farrow to Feeder Swine
Number of Animals: 3i6� . 00 sows "4 She pAle
(Design Capacity)
STORAGE STRUCTURE: Anaerobic Waste Treatment Lagoon
APPLICATION METHOD: Irrigation
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops
in the fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply
more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall be applied to land eroding at less than
5 tons per acre per year. Waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4_ Do not apply waste on saturated soils, when it is raining,
or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed
under DWQ regulations.
Page: 1

0
ANIMAL WASTE UTILIZATION PLAN
5. Wind conditions should also be considered to avoid drift and
downwind odor problems.
6. To maximize the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more than 30
days prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. If
you choose to change methods in the future, you need to revise this
plan. Nutrient levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from your
waste management facility. In some cases you may want to have plant
analysis made, which could allow additional waste to be applied.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
This waste utilization plan, if carried out, meets the requirements
for compliance with 15A NCAC 2H .0217 adopted by the Environmental
Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
'456 sows x 7.3 tons waste/saws/year = 3328.8 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
3(A
P1CA5 sows x 6.5 lbs PAN/sows/year = 2964 lbs. PAN/year
5 ZO 01&V1'-1 Ar �
pe'h;rAA l ---�
Applying the above amount of waste is a big job. You should plan time
and have appropriate equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface 'application.
FArnn C4�Ac,141 t7' 3(04 Soe..�5 �� �.�.��a�-4+ ��{� �arr►.2� -�a�a
t f 6*, AC,�
Wog S C'. Cwjo.r seo� 5� ate;
i
I Page - 2

ANIMAL WASTE UTILIZATION PLAN
TABLE 1: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
-------
APPLY
RESID.
APPLIC
METH
N
TIME
9219
1
To
BH
5.3
265
0
9
2385
I
MAR -OCT
9213�l G 11 150 10 19
1450 1I SEP -MAY
9219 1A LeA BH 4.0 1200 0 3 1600
I MAR -OCT
9219 "1A SG 1 150 0 3 1150
I SEP -MAY
END
I
TOTAL13585
- Indicates that this field is being overseeded (i.e. interplanted)
or winter annuals follow summer annuals.
NOTE: The applicator is cautioned that P and K may be over applied
while meeting the N requirements. In the future, regulations may
require farmers in some parts of North Carolina to have a
nutrient management plan that addresses all nutrients. This plan
only addresses nitrogen.
Page: 3

ANIMAL WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
See required specification 2.)
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
---
or
-------
APPLY
RESID.
APPLIC
METH
N
TIME
END
TOTAL 10
Indicates that this field is being overseeded (i.e. interplanted) or
winter annuals follow summer annuals.
In interplanted fields (i.e. small grain, etc, interseeded
in bermudagrass), forage must be removed through grazing,
hay and/or silage. where grazing, plants should be grazed
when they reach a height of six to nine inches. Cattle
should be removed when plants are grazed to a height of four
inches. In fields where small grain, etc, is to be removed
for hay or silage, care should be exercised not to let small
grain to reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too
high and this will definitely interfere with stand of
bermudagrass. This loss of stand will result in reduced
yields and less nitrogen being utilized. Rather than
cutting small grain for hay or silage just before heading as
is the normal situation, you are encouraged to cut the small
grain earlier. You may want to consider harvesting hay or
silage two to three times during the season, depending on
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late
September or early October. Drilling is recommended over
broadcasting. Bermudagrass should be grazed or mowed to a
height of about two inches before drilling for best results.
Page: 4

ANIMAL WASTE UTILIZATION PLAN
** Acreage figures may exceed total acreage in fields due to
overseeding.
* lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and 2 above:
CROP CODE
CROP
UNITS
PER UNIT
BH
SG
HYBRID BERMUDAGRASS-HAY
SMALL GRAIN OVERSEEDED
TONS
AC
50
50
TABLE 1
TABLE 2
TOTAL
TOTALS FROM TABLES 1 AND 2
ACRES
LBS AW N USED
12
3585
0
0
12
3585
BALANCE
-521
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.
Page: 5

ANIMAL WASTE UTILIZATION PLAN
*** This number must be less than or equal to 0 in order to fully
utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffers, filter strips along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than the
acres shown in the tables.
See attached map showing the fields to be used for the utilization of
animal waste.
SLUDGE APPLICATION.
The waste utilization plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient
rich and will require precautionary measures to prevent over application
of nutrients or other elements. Your production facility will produce
approximately 501.6 pounds of plant available nitrogen per year.in the
sludge.
If you remove the sludge every 5 years, you will have approximately 2508
pounds of PAN to utilize. Assuming you apply this PAN to hybrid
bermudagrass hayland at the rate of 300 pounds of nitrogen per acre, you
will need 8.36 acres of land. If you apply the sludge to corn at
the rate of 125 pounds of nitrogen per acre, you will need 20.064 acres
of land. Please be aware that these are only estimates of the PAN and
land needed. Actual requirements could vary by 2516 depending on your
sludge waste analysis, soil types, realistic yields, and application
methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the
soil at the time of irrigation such that runoff or ponding occurs. This
rate is limited by initial soil moisture content, soil structure, soil
texture, water droplet size, and organic solids. The application amount
should not exceed the available water holding capacity of the soil at the
time of irrigation nor should the plant available nitrogen applied exceed
the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables 1 and 2. Failure to apply the recommended rates and
Paae: 6

ANIMAL WASTE UTILIZATION PLAN
amounts of nitrogen shown in the tables may make this plan invalid.
.The following table is provided as a guide for establishing application
rates and amounts.
Tract
Field
Soil Type
Crop
Application Rate
(in/hr)
Applic. Amount
(inches)
9219
1
To
BH
o.5o
*0.95
9219
3A
LeA
BH
0.55
*0.95
9219
"1
SG
9219
" lA
SG
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations, the application amount shown cannot
be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180.00 days of temporary storage and the
temporary storage must be removed on the average of once every 5.00
months. In no instance should the volume of the waste be stored in
your structure be within the 25 year 24 hour storm storage or one foot
of freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply the
correct rates to the acres shown in Tables 1 and 2. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may
make this plan invalid.
Call your technical specialist after you receive the waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate prior to applying the waste.
NARRATIVE OF OPERATION
Page: 7

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
4
1. Animal waste shall not reach surface waters of the state by
• runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more: tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
5. Odors can be reduced by injecting the waste or disking after
waste application_ Waste should not be applied when there is
danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina" for guidance.)
7.' Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
B. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be considered.
Page: 8

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for
• spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to
wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly into water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
the site.
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 9

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
18. If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22. Waste shall be tested within 60 days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when these
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be
maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North
Carolina regulations.
Page: 10

ANIMAL WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Naive of Farm;CRAIG COLLINS
Owner/Manager Agreement
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
North Carolina Division of Water Quality (NCDWQ) before the new
animals are stocked. I (we) also understand that there must be no
discharge of animal waste from this system to surface waters of the
state from a storm event less severe than the 25 -year, 24-hour
storm. The approved plan will be filed on-site at the farm office
and at the office of the local Soil and Water Conservation District
and will be available for review by NCDWQ upon request.
Name of Facility Owner: CRAIG COLLINS
(Please print)
Signature: Date: v' ,�O Y7
Name of Manager (I different from owner):
Signature:
Date:
Name of Penson Preparing Plan: fPlease print)M. Dawn Williamson.
Affiliation:Sampson SWCD Phone No.
Address (Agency): 84 County Complex Road
Clinton NC 28328
Signature:J� 1 44SYV,5Date:
�--3O-C=� 01
Page: 11

5''°�r�`
PROM
+ 5 x+ Y�� j}' + , ;"•' il4� :uv.uy�y�. ���v t{+
oi
ILI
� �� E. 6" i• lRl "Y ����q" �,+'„v��✓r ,�.` F s: © � ' ++.1.. yc�� pl � s 1 1.. F:�
p.
+'y S9 Cj V 1�6'' F yi �yn�cgyNY 1 +4 v i n 'J1 • i d �1 (M1'
S R
!.11911
"151
j
i
�6+ip E t �t� • � 1 'lY WWW:::"""�V! R. : /� - z) " 1 +_T�1,�� i�d 55 �/! 6' `"