820488_CORRESPONDENCE_20171231

NORTH CAROLINA
Department of Environmental Qua

State of North Carolina
Department of Environment
and Natural Resources
Michael F. Easley, Governor
William G. Ross Jr., Secretary
Gregory J. Thorpe, Ph.D., Acting Director
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
William T. Herring
Pork Chop Hill Finishing #6
PO Box 300
Newton Grove NC 28366
Dear William T. Herring:
1 •
NCDENR
NC*UH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
September 4, 2001
Subject: Notification for Wettable Acre Determination
Animal Waste Management System
Pork Chop Hill Finishing #6
Facility Number 82488
Sampson County
A letter dated January 15, 1999 was sent to advise you about concerns associated with Certified Animal
Waste Management Plans and the method by which the irrigated acres within the plans were calculated. Only
the acres that are wetted can be credited in the waste management plan as receiving waste application. Any
acreage within the plan that can not be reached by waste application equipment can not be used as part of your
plan.
An evaluation by Scott Faircloth on 6/28/99 was made to review the actual number of acres at your
facility that receive animal waste during land application. The evaluation of your facility has yielded one of
the following two results as indicated by the box marked with an "X'.
Category 1:
❑ The evaluation of your facility could not be completed due to a lack of information. Please
contact your Technical Specialist to assist in providing Scott Faircloth the necessary
information to potentially exempt your facility from undergoing a complete wettable acre
determination. Please submit this information to Scott Faircloth, at 225 Green Street, Suite
714, Fayetteville, NC 28301, within in 90 days of the receipt of this letter. If you have any
questions please contact Scott Faircloth at [phone]. If within 90 days you are
unable to provide Scott Faircloth with the information you are automatically required
to complete a Wettable Acre Determination as described by Category 2 below, within
180 days of receipt of this letter.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunit} AiTirmatire Action Employer 50% reeycled/10% post -consumer paper

Notification for Wettable Acre Determination
Animal Waste Management System
Page 2
Category 2:
Your facility has been identified by the Department of Environment and Natural Resources
as a facility that may have overestimated the number of acres actually receiving animal
waste. Therefore, some or all of your fields may be exceeding the allowable loading rates
set in your Certified Animal Waste Management Plan.
In order to resolve this issue, please contact a designated Technical Specialist to have him
or her conduct a Wettable Acre Determination for your facility. The Technical Specialist must
be one that has been approved by the Soil and Water Conservation Commission to conduct
Wettable Acre Determinations. Many Technical Specialist with the N.C. Cooperative Extension
Service, the Soil and Water Conservation Districts, the Natural Resources Conservation
Service, and the Division of Soil and Water Conservation have received this special
designation. You may also contact a private Technical Specialist who has received this
designation, or a Professional Engineer.
All needed modifications to your Animal Waste Management System must be made and
the Wettable Acres Determination Certification must be returned to DWC within the neat
180 days. If the needed modifications are not made and if the form is not returned within the
required time, DWQ will be forced to take appropriate enforcement actions to bring this facility
into compliance. These actions may include civil penalty assessments, permit revocation,
and/or injunctive relief.
Once a Wettable Acre Determination has been completed, a copy of the attached Wettable
Acre Determination Certification must be submitted to the address listed on the form. Please
note that both the owner and the Technical Specialist must sign the certification. A copy of all
the Wettable Acre Determination documentation that applies to your Waste Utilization Plan
must be kept at your facility. DWQ and the Division of Soil & Water Conservation Staff will
review all documentation during their annual visit of your facility. An additional copy must by
kept on file at the local Soil & Water Conservation District Office. Please note that if you install
or modify your irrigation system, a designated Irrigation Specialist or a Professional Engineer
must also sign the Wettable Acre Determination Certification.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Sonya Avant of our
Central Office staff at [phone] ext. 571.
Sincerely,
lGre.FThorpe, D.
cc: Fayetteville Regional Office
Sampson County Soil and Water Conservation District
Facility File
Newton Grove Grain and Feed

Doug Ni®ond
• TD-M Forms
Box 300
' Newton Grove-N.C. 28366
910-594-C219
TDM.-Farrns,:r ...
.:
„ -.
VD
June 10, 1999
MN t 4 1999
Division of Air duality FAYETTEVILLE
REG. GFF!CE
Fayetteville Regional Office
Wachovia Building
225 Green Street Suite 714
Fayetteville, N.C. 28301
Dear, Sir or Madam:
I am writing you per instructions received in a letter from Mr. Alan Klimeck dated May 27, 1999
s
cwncq*ft temporary odor rules for swine farms_ In his letter Mr. Khmeck stated that if I believed
that�gt is groblcmatic for you to comply with any of these required management practices please send
F;
writtea documentation by August 1,1999." We believe that it is problematic for our farms to comply
with requirement No. 7. In addition we also question the effectiveness of requirement No. 1 and
believe that both of these rules will have a negligible or adverse effect on odor and could produce
negative impacts on water quality.
Requirement No. 7 states that flush tanks should be covered or the fill pipes should be extended below
the surface of the wastewater of the tank From personal observation, I feel that these tanks and the
way that they fill are not a significant source of odor on a swine farm. By covering or extending the fill
pipes the farm operator will not be able to observe the rate at which the recycle water fills the tank
This is critical because the tanks are often set up to dump periodically with a timer. If the tanks dump
before they are filled the result is insufficient, water to completely move the main= out of the pit thus
creating more odors from the building Conversely, if the tank Us before it is time to dump, you risk a
spill via a blocked overflow pipe.

June 10, 1999
Page 2
Requirement No. 1 states that the discharge point of the pipe from the buildings shall enter below the
surface of animal wastewater lagoons. This requirement will make it impossible for the operator to
observe what is being discharged from the buildings. A pipe that becomes clogged may go undetected
leading to a hack up of recycle water in the pit with the potential to spill out of the building_ The
operator also will not be able to detect any unusual discharge such as fresh water from a leak or
malfunction- The added turn in the pipe needed to direct the flow under the lagoon surface could also
increase the chance of a blockage.
Because of these concerns we have not covered or extended the Ell pipes on the damp tanks at any of
the farms that we own or manage. We have extended our discharge lines under the surface of the
lagoons. We have advised our growers to extend their discharge lines but have given them their choice
on how to handle the flush tanks. Most have opted to leave them as is. I have included a list of farms
associated with TDM in your region. This includes farms, which we own, manage, or grow hogs on
Contract for us.
"Thank you for your attention to this matter and if you have any questions please feel free to contact me.
Sincerely.
Doug Niemond
EwArortmental Manager
Cc:DWQ Mr. Bob Heath

n
FARM NAME DWQ FACILITY NO.
TDM#1 WALLER
82-378
TDM92 TARHEEL FARMS
26-25
TDM#5
TDM#6 CASEY
82-274
TDM#7 WILSON
82-196
TDM#8 ROSE
82-101
TDM#11 HARRELL
82-275
TDM#12 A&W
82-97
TDM#13 S&O
82-282
TDM#14 MARK BAREFOOT
82-521
TDM#16 3D
82-210
TDM#17 DODSON
82-390
TDM#18 GIDDENS
82-100
TDM#19 BASS
82-221
TDM#20 THORNTON
82-47
TDM#21 HERRING
8249
TDM#23 DAUGHTRY
82-601
TDM#24 WILLIAMS
82-625
TDM#25 SUTTON
82-718
TDNM6 CYPACK
26-72
TDM#30 BEST BROTHERS
82-699
TDM#100 BAREFOOT NURS
82-58
TDM#102 SULLIVAN
82-175
TDM#103 EDWARDS
82-177
TDM#104 CASEY NURS
82-655
PCH
82-94
PCH-FINISHING
82�7
PCH 6
82-488

State of North Carolina
Department of Environment,
Health and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Govemor
Jonathan B. Howes, Secretary
A. Preston Howard, Jr., P.B., Director
January 23, 1997
M. M�: �
TO: Fayetteville Regional Water Quality Supervisor
FROM: Sue Homewood
SUBJECT: Notification of Facility Number Change
RECMr'ftI16Ea7
JAN 2 7 1991.
REG. OFFjoji
The following changes have been made to the Animal Operations Database. Please make
appropriate changes in your files.
Facility number 82-93 was a duplicate of 82-67 and 82-488. Facility numbers
82-67 and 82-488 are accurate and 82-93 was deleted from the animal operations
database.
If you have any comments or questions please feel free to call me at [phone] ext 502.
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] PAX 919-733-9919
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

o f W A r�R Michael F. Easley, Governor
C� Q William G.Ross Jr.rSecretary
C. North Carolina Department of Environment and Natural Resources
j r Alan W. Klimek, P. E., Director
0 Y
Division of Water Quality
May 1, 2003
William T. Herring
Pork Chop Hill Finishing #6
PO Box 300
Newton Grove NC 28366
Subject: Certificate of Coverage No. AWS820488
Pork Chop Hill Finishing #6
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
Dear William T. Herring:
On April 28, 2003, the North Carolina General Assembly ratified Senate Bill 733 which directs the
Division of Water Quality (Division) to extend the expiration date of the Swine. -Waste Operation General
Permit AWG100000. Therefore, the General Permit has been re -issued by the Division to extend the
expiration date to October 1, 2004. During the period of this extension the Division will be working with
all interested parties on the development of a new version of the Non -Discharge General Permit.
In accordance with your application received on February 18, 2003 and in accordance with the directive
of Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to William
T. Herring, authorizing the operation of the subject animal waste collection, treatment, storage and land
application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AWS820488 which expired on April 30, 2003.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Pork Chop Hill Finishing #6, located in Sampson County, with an animal
capacity of no greater than an annual average of 735 Feeder to Finish swine and the application to land
as specified in the facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to
Wean or Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are
unneccessary, they may be replaced by an equivalent number of sows. Any of the sows may be replaced
by gilts at a rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until October 1, 2004. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
fIfI�LRR
Non -Discharge Permitting Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
Customer Service Center
An Equal Opportunity Action Employer
Internet httpJ/h2o.enr.state.nc.us/ndpu
Telephone [phone] Fax [phone]
Telephone [phone]
50% recycled/10% post -consumer paper

Upon abandonment or depopulation for a period 'of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per MRCS standards a 100 foot separation shall be maintained between water supply wells and any
lagoon or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties. and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office_ The Regional Office
Water Quality Staff may be reached at [phone]. ­lf you -need additional information concerning
this COC or the General Permit, please contact 1 R loshi at (9I9) 733-5083 ext. 363.
Sincerely,
I/ /4ZK
for Alan W. Klimek, P.E.
Enclosures (General Permit AWGIOOOOO)
cc: (Certificate of Coverage only for all cc's)
Fayetteville Regional Office, Water Quality Section
Sampson County Health Department -
Sampson County Soil and Water Conservation District
Permit File AWS820488
NDPU Files

ANIMAL WASTE UTILIZATION PLAN
Producer:
Location:
Telephone:
Type Operation:
Number of Animals:
(Design Capacity)
STORAGE STRUCTURE:
APPLICATION METHOD:
HERRING
P.Q. BOX 300
NEWTON GROVE NC 28366
910-594-0219
1V4%`: ER n`s'nL1T'� SEGi"i©!y
FEE $ 2003
NON -DISCHARGE PERTY71TTING
Existing Combination Swine Farm
6685.00 swine
Irrigation
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount. of commercial fertilizer required for the crops
in the fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient.
,daste should be analyzed before each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several f actors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
I. Always apply waste based on the needs of the crop to be
grown anti the nutrient content of the waste. Do not apply
more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall be applied to land eroding at less than
S tons per acre per year. waste may be applied to land
erodincT at 5 or more tons per acre annually, but less than
10 tons oer acre ner year provilding thy= adequate filter
strips are estab?ished.
? _ Do not apply waste on sat- rated soils, when it 1s raining,
or when the surface ,s frozen. wither of these conditions
may result in, runoff to sur=ace waters which is not allowed
under DWQ regulations.
r '
T parry- l

r e
ANIMAL WASTE UTILIZATION PLAN
5 _ Wind conditions should also be considered to avoid dr, -Et and
downwind odor problems.
6. To maximize the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more than 30
days prior to planting a crop or forages breaking dormancy.
n]ecti nc the waste e or disking Will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. If
you choose to change methods in the future, you need to revise this
plan. Nutrient levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analvsis report from your
waste management facility. In some cases you may want to have plant
analysis made, which could allow additional waste to be applied.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
This waste utilization plan, if carried out, meets the requirements
for compliance with ]SA NGAC 2H 0217 adopted by the Environmental
Management Commission. ^
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, tt3, tons, etc.)
6685 swine x 3.6949887B485 tons waste/swine/year = 24701 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
6685 swine x 3.9364248317I lbs PAN/swine/year = 26315 lbs. PAN/year
Applying the above amount oz waste is a bit 'ob. You should plan
time and have appropriate equipment to aDQ!v the waste in a timely
manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
D=,To . 1)

ANIMAL WASTE UTILIZATION PLAN
TABLE 1: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE « CLASS-
CROP
YIELD
LES
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PEP. AC
AC
USED
-----
or
-------
APPLY
RESID.
APPLIC
METH
N
TIME
11567
1
Wan
BP
1
205
0
T6
3280
I
MAR--OCT
11567
--1
WA
1 1
100
0
_
�6
I
11600
S E P -APR
11567
12
1WaB
IBH
1
I5.5
1275
10
11D
12750
MAR-OCT
11567
WA
1
0
10
1000
1-2
1 I
I
1100
I
SEP-APR
_. 67
0
10
2050
13
IWaB
IBP
�4.1
I205
MAR-OCT
11567
-3
D
IWAI
11
1100
1
110
SEP0APR
11567
4
2H
5.5
jWaB
I
1275
10
16-
11MAR650
OCT
11567
f
WA
100
6
600
1-4
12-
I0
ISEP-APR
4231
6.1
17
jNoA
I
IBH
1305
10
15
li5R--5 T
4231
�-7
IWA
li
Iioo
Io
is
I500 APR
4720
�-15
T — _
BH
5.5
1waR
li
I275
10
Ia
I2200
MAR-OCT
4720
TI�S
—10
I
1W.A.
li
1-1-00
is
1800
SEP-APR
11568
5
BH
5.5
275
0
lwaE
1'
I-
I
123
16325
kR-OCT
11568
�_6
{
IWA
11
1100
10
123
12300

ANIMAL WASTE UTILIZATION PLAN
1SEP-APR
11568 I8 WaB �2H 5.5 �275 10 15 �1375
MAR-OCT
�
_.�WA SG� ��i � � �i �ioo �� 15
SOG-APR
1 �-ND, I
1
TOTAL 129455
- Indicates that this `ield is inning overseeded (i.e.
interplanted) or winter annuals follow summer annuals.
NOTE: The applicator is cautioned that. P and K may be over applied
while meeting the N requirements. In the future, regulations
may require farmers in some parts of North Carolina to have a
nutrient management plan that addresses all nutrients. This
plan only addresses nitrogen.

ANIMAL WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
See required specification 2_)
TRACT'
FIEND
SOIL TYPE & CLASS-
CROP
YIELD
LSS
Comm N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
----
or
-------
APPLY
RESID.
APPLIC
METIE
N
TIME
END
TOTAL 10
Indicates that this field is being overseeded (i_e. interplanted) or
winter annuals follow summer annuals.
x* Acreage figures may exceed total acreage in fields due to
overseeding.
* lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COHN N) supplied.
The following legend explains the crop codes used in tables I and 2 above
CROP CODE
CROP
UNITS
PER UNIT
BH
HYBRID BERMUDAGRASS-WAY
TONS
50
SP
HYBRID SERMUDAGRASS-PASTURE
TONS
50
WA
WINTER ANNUALS (I-E. Small Grains, etc.)
AC
i00
TOTALS FROM TABLES l AND 2
ACRES I !.CBS AW N USED

TABLE 1
TABLE 2
TOTAL
ANIMAL WASTE U 1LIZATION PLAN
e3
0
83
29455
0
29455
* * BALANCE -- 31 ^ 0
-------------------
This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.

ANIMAL WASTE UTILIZATION PLAN
** This number must be less than or equal to o in order -o fully
utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buf-fers, Li ter szriT)s along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
-full appl i cat? on rates due to equinment limitations- Actual total
acres in the fields listed may, and most likely will be, more than
the acres shown in the tables.
See attached map showing the fields to be used for the utiJizatior_ of
animal waste.
APPLICATION OF WASTE BY iRRTGATION
The irrigation application rate should not exceed the intake rate of the
soil at the time of irrigation such that runoff or ponding occurs. This
;ate is limited by initial soil moisture content, soil structure, soil
texture, water droplet size, and organic solids. The application amount
should not exceed the available water holding capacity of the soil at the
time of irrigation nor should the plant available nitrogen applied exceed
the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown • in Tables ? and 2. Failure to anr)ly the recommended rates and
amounts of nitrogen shown in the tables may make this p1 are invalid
The following table is provided .as a guide for establishing application
rates and amounts.
Tract I Field I Soil T-,rpe I Crop
ApplicatioP. atelADplic. Amount
(in/hr) I (inches)
11567 1
I waR
I BF
0.5o
I *0.16
i
57 I 2
I inia3
I EH
I 0.
�_;0
*0. 56

ANIMAL WASTE UTILIZATION PLAN
�1567
I
13
I
J WaB
I
J sF
I
I 0.60
I *0.96
zi567
#
1 4
I
I WaB
I
I si
#
I 0.60
I *0.96
115 6 7
I
I `'
I
I
I
I WA
!
I
11567
I -2
I
I
WA
I
I
1? 557
I --3
f
I
I
J WA
I
I
E
I
1"q57 J
1
-4
I
I
I
J W.A
I
I
I
I
I
11568 1
6
#
I WaB
I
12
I
I 0.60
I *0.96
I
11568 J
8
I
I WaB
I
I 2H
I
I 0.60
I
J *0.96
1
11568 #
--6
I
I
#
I tml
I
I
1
#
I
I
I
I
4231 1
7
I NUA
I .ter
J 0.50
? .30
I
4231 I
-7
#
I
I
I WA
I
I
I
#

ANIMAL WASTE UTILIZATION PLAN
4720 5 waB I I 0.60 I *0.96
I I I i
4720 I -5 I I WA I I
I f I I
This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations, the application amount shown cannot
be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your .facility is designed for 180.00 days of temporary storage and
the temporary storage must be removed on the average of once every
6.00 months_ In no instance should the volume of the waste be stored
in your structure be within the 25 year 24 hour storm storage or one
foot of freeboard except in the event of the 25 year 25 hour storm.
It is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply the
correct rates to acres shown in `Fables ? and 2. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may
snake this plan invalid.
Call your zechnical Specialist a.iter you receive `he waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate prior to applying the waste.
NARRATIVE OF OPERATION

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or J
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. if the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with'a landowner who is within a
reasonable proximity, allowing him/her the use cf the land for
waste application_ It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate or application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
5. odors can be reduced by injecting the waste or disking after
waste application_ Waste should not be applied when there is
danger of drift from the irrigation field.
G. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "weather
and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during
rainfall events, cr when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit grownh.The potential for sal: damage from animal
waste should also be considered.
Page: 10

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
10. waste nutrients shall not be applied in fall or winter for
spring planted crops on soils wi th a high potential for
leaching. Waste nutrienc loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients_ waste shall not be aonlied more
than 30 days prior to planting of the crop or forages breaking
dormancy -
!I. Any new swine facility sited on or- of ter October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet From any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips) .
12. Animal waste shall not be anniied closer than 100 feet to
wells. --
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
la. Waste shall be applied in a manner not to reachhi other property
and public right -or -ways.
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
Grassed waterways that discharges directly into water courses,
and on other grassed waterways, waste shall be .applied at
agronomic rates in a manner that causes no runoff or drift from
the site.
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, 'etc., shall not be discharged into the
animal waste manaaemenL sysLem.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc . ) . Areas shall be fenced, as necessary, to
protect the vegetation. vegetation such as trees, shrubs, and
other woody snec?es, etc., are limited to areas where considered
appropr-ate. Laccon areas should be kept. mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 11

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
78. if animal production at the facility is to be suspended or
terminated, the owner is Yesponsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of are illegal discharge, pollution and erosion_.
19. waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept or -
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste As used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season..
21. highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22. Waste shall be tested within Go days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element_ Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when these
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained_ Soil and waste
analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
years. waste application records for all other waste. shall be
maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North
Carolina regulations.
Page: 12

ANIMAL WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of Fax.n: PORK CHOP HILL
Owner/Manages Agreement
(we) understand and will follow and implement the specizications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new -
iacili ties Will reaui re a new certlfi cati on to be submitted to the
North Carolina Division of Water Quality (NCDWQ) be=ore the new
animals are stocked. i (we) also understand that there must be no
discharge of animal waste from this system to surface waters of the
state from a storm event less severe than the 25-year, 24-hour
storm. The approved plan will be filed on -site at the farm office
and at the office of the local Soil and Water Conservation District --
and will be available for review by NCDWQ upon request.
Name of Facility Owner: HERRING
(?lease print)
Signature:
Date:
Name of Manager differ t from o er)t�� ,�;1� , -TOM
urv.,s
Signature:L Date:
Name of Person Preparing Plan: (Please print)W3.lson Spencer
Affiliation:NRCS Phone No.
Address (Agency): 84 County Complex Rd.
Clinton NC 28328
signature. Fv
mu�� �'�� Date.
f
Page: 13

ANIMAL WASTE UTILIZATION PLAN
ANIMAL WASTE UTILIZATION AGREEMENT
(Needed only if additional land has to be leased, etc.)
hereby give
permission to apply animal waste from his Waste Utilization -System
on acres of my land for the duration of time shown below.
The field(s) on which waste can be applied are shown on the
attached map.
l understand that this waste contains nitrogen, phosphorous,
potassium, andvothAr trace elements and when properly applied
should not harm my land or crops. i also understand that the use
of Waste will reduce my need for commercial fertilizer.
Adjacent Landowner:
Waste Producer:
Technical Representative:
SWCD Representative:
Date:
Date:
Date :
Date:
Term of Agreement: ,19 to
(Minimum of Ten Years on Cost Shared items)
(See Required Specification No. 2.)
Page_ 14

ANIMAL WASTE UTILIZATION PLAN
STATE OF NORTH CAROLINA
COUNTY OF
a Notary
Public of said County, do hereby certify that
, personally appeared before me this day and acknowledged the due
execution of the foregoing instrument.
WITNESS my hand and official seal this
19
My commission expires
(SEAS)
day of
Notary Public.
Page: 15

ANIMAL WASTE UTILIZATION PLAN
Waste ,Utilization _- Third Party Receiver Agreement
hereby agree to apply waste
_generated by in a manner that meets the
Waste Utilization Standard (633), or use an alternative waste
utilization system that has beers accepted in writing by the
Division of water Quality,
Third Party Receiver:
Date:
Term of Agreement: to
(Minimum Ten Years on Cost -Shared Items)
STATE OF NORTH CAROLINA
Kil14AN,9 WAKaft
a Notary
Public of said County, do hereby cer-iiy that
personally appeared be --':'ore me this day and acknowledged the due
execution of the foregoing instrument.
WITNESS my hand and official seal this day of
i9
My commission expires
(SEAL)
Notary Public —
Page: 15

.hd
.eh
_po 0 .
WORKSHEET FOR CALCULATING PAN AND TONS OF WASTE
FROM COMBINATION SWINE OPERATIONS
Operation Code: 6 Combination Swine Farm
APPLICATION METHOD: I irrigation
Type,Operation
Number
Tons Waste
PAN
Animals
per Animal
per an.
NUMBER
OF WEAN TO FEEDER PIGS:
.40
.48
NUMBER
-OF FEEDER TO FINISH HOGS:
4485
1.9
2.3
NUMBER
OF FARROW TO WEAN SOWS:
2000
6.1
5.4
NUMBER
OF FARROW TO FEEDER SOWS:
7.3
6.5
NUMBER
OF FARROW TO FINISH SOWS:
200
19.9
26
TOTAL NUMBER ANIMALS:
6685
TONS OF WASTE PRODUCED PER YEAR:
WEAN TO FEEDER:
0 tons
FEEDER TO FINISH:
8521.5 tons
FARROW TO WEAN:
12200 tons
FARROW TO FEEDER:
0 tons
FARROW TO FINISH:
3980 tons
TOTAL WASTE:
24701.5 tons
P- PRODUCED PER YEAR:
WEAN TO FEEDER:
0 lbs
FEEDER TO FINISH:
10315.5 lbs
FARROW TO WEAN:
10800 lbs
FARROW TO FEEDER:
0 lbs
FARROW TO FINISH:
5200 lbs
TOTAL PAN:
26315
AVERAGE TONS OF WASTE PER ANIMAL PER YEAR: 3.69498878085
AVERAGE PAN PRODUCED PER ANIMAL PER YEAR: 3,93642483171
SLUDGE PAN PRODUCED PER YEAR: BROADCAST
WEAN TO FEEDER: 0 lbs
FEEDER TO FINISH: 1659.45 lbs
FARROW TO WEAN: 1760 lbs
FARROW TO FEEDER: 0 lbs
FARROW TO FINISH: 860 lbs
TOTAL SLUDGE PAN: 4279.45 lbs
AVERAGE SLUDGE PAN PER ANIMAL PER YEAR: 0.640157068063

*•/iI''�'•0 :'� '� .F} �''� '� q'' 1►r; •. ',, .: b .I;3'��: i k .':1. s•;%`�'. '"kg {a *'`,. a. �
�. + �1T•' 1 ' ~�� +.L / .t••+ ,t Ei S •y ►♦!. �e �r • �1 a ••yrl�w• Y�! a •', `�+xi I q�_ 'a / � if
iR r
U.,, l 1I(f /,'1� Jk✓ i s�.i,431, f•��. \1. •1rY •�' ,• 1,• �i G•r I !' ' -iG .1:
� '' s '•? ,.' yf.,{�,'�` �.,��SijR r-t ;��i>'
k : • -' a ` �Iq,, r`^ti} } i1y�1'.. r Ji^ ' f et��•'%�`Lf �F t, L�'•jt�'!`R. �4t �+�i t•.. r�� s_S;
•.fr:;�rr,.- �. 1 �r[f:,,'�.� .��++i {' e."irl+ 5 .! t-er,•_•! �� yj pij �. r,.r• ..{:'� ,r ='•r-i
!� . , s s' ,,• - r- i . �SI..S '.�„l,Yr �` 1 1� � i.v.� • - �3 -
-fill
.: ��f � y+► -•�7 ti- 'w^.'.i rylf:/� r'x i.k-1 �- •t�: �a ..~,.', �i,�1 k y .+ t .' r.
` r y* � •T" _ ••tom - + - .'� .. J'+ : 4'� ]': � _ t' .%� •'� '• tj/ /a' j ' ��,,7�t - •'1� �a i.
•,aR ..�'.�;--f _' • w'w/ 'a- •, -, i e - t�- J� f�'� it�•'k'.S ��'.� i, _t. a- r. 1
+ - !. G it f•. • :s.:.�r: i_ �}� }:�Et, �'y, tti J^y�� 7S'-#�F -' �-�'.
,B�r �; �:. x,�,f/,. rs'• _ a �_ � •mac r • !r�•� �f'�r: G �t i ° � ���--''J
c �• � -- may, '.ii .
o�, i°qI• . �, . t`t. � • ey
'�':, �.yiZ► ,a -� •t �f ,i.'r4t'' r+1:•�` 1'" n - } t•'} ,r. +f4�';�iZ�R�e( I�' �_T'T•y', i.•.
ix :sA:� i- � K; G"� ,. 8� ''` `' �I'" 4�L�{r�}• :i1�•��'�J����t>:" L• "t. ! F �
:i ^s , a ,--:�." ,,F•rt E F,�'L� � �'.' .: ;` ' .-sc
'wl ��. r•I 1! ' s f ` y' -u i jj[ � #'t,�r itf+ h•�1: ii�,�.= , (IIiiiiiii� �..
. t , �:�� .• _::'EE�l44l;; ,c �.,� { � ,� •y �„ x • v f,,' •.3 + - ter'!. j':2,,,'� `� � �� � • ! ` �+;�'tt �.'{` �, ` :a�•,a*`�,�fiLT��yj� j�• f ':F Y:4 i� i�J _ 1 r ! r•. 1 {r ' � ' 4
;� =T
q�'7�y t yi !: t y[�a `• ,F's;fsj•'rs.s•/I]%l� -� !. ;Ly;••>
i- r ; :��3EiI ., ifl � 1• ,i . a'Al
1.
�if�
ri, ,, ] t Il! 1 •F< - , - Y•�IY��"+ ;yf y.� ��+:� K�} .i' y�
1 �fa�'fr• Ci Ki< iL .( �•�s r. .1i4 .,..y :y:�:f ,%1 - •�.'.. •.'•, .'►.
''$f a'• .t , r.9"i 1 + . fit, *: i
'•any
� 7t�� �! �; .t �i �•'.i �. .'I' '�''�" �1 ..,,ry,�•�'" 1r 'd.�.r
! .•'�'�i' �lrr�C! � i . •} T i>too
'� .:• `,�- - ' d�r,;i : � wt, ! yr:fit j7�, :: r f ;,,r
141'.ti �•](-^� I+�1j�i.,:•�: f VC.:ati .�'�� •1 � �}•�)�a %t �{;�V•�l 11, r ilw �N ;Sel: '+y.�f•,�. a1!"+' � t# .•j• r "g � , i L
�yr'�• f'��`f Ij^ _�rj��j¢..i;. �_.' �i. '1 ilt.1 '� ,`',`frtf=/tiF'1Y-14! -'� ;1.�i'..�ty �:'f i'i''.h'•�'ir, .�.L•�>+I'V ,.e �, yy., •Iky'�T 1^ -'..
t�"1.9 ►, s i � * i f q t 4., 'a •d. 7 f�1' } s �j�If,fD •1 .r jA•}
y �k 11;iC ' �;, -• r• 9� �a'I I.,f 1 .a r J'+ l�r:•"f � fr
f �r '�{sy �.!'• i f ?`,.{E r }. �.'',, �;. t �. y'=J� la's' , , +
f'
M.� fp -4. a i. t !•. � ,. '1. r�',. ` t' r-•I ii .i ytj i� :,I { d� • r� f• l) a
.����•�,•:•�11�'r; :� ., �'. � �• T �{ �Aj� 1. ',!f;{ !f�`��wiA .,e'4• ' . .. ,SZi'.. .t :r, .i �`�' �., ..,�;'. : i�f; .•r1: !;, 4 J.r'�.'•'s ,;i ;" ' rS 4-
+�, �- .p f��,+fL, i ��.:I.•ff5 ',il z. .!1 + !ix'arl1+ . i q •.r.{}1 .ai.s'r r;Fi' 'LG-rs 1, -r I' ,�+: liif r + .}'4.,.M.•*;, �• tj,v
'A a A9+P5. L� F ld {•. .�1 .'id 'r '•1': � r -0i � I r' � ''' 1 • � -,n :I
.e ±� t lu� F �•H r '; � r Y I, t+ 1 ;�• i h. irr1':1Vr I .� l .4 (' y f �?�a J
r,' 's'� •f '�r1` '�•' •: • 'j,' �;' , rs F„`rF'T:' '�:q ftyy�" •r }+� I, 4+ , , 'j 4 r 4 ,r.. �.. 7 , ti : 1 f(I'i! fr' d 1 \i $ r'r' i�� i' y1
,a' H y
.w TI' 'a 4' , 1•i- 'y, sl. '' I^4rl S 'i7 t T,;.
ct,',k} '': •T+ ��•i f!�II, "'► Ili, i.i•�.•,�{��.; I I+w };fit,, ,+^ " .: ,'.-, •,uT}hfr f1 {'I y I {p,y�•i' .1• ri'
'ry, i� :� ►i�f6' r'��ri*',•�'FS } i ,��,(y��� t ��'M.:+.:': �'l�" .;� :J;: ',; d�';11:';�' ''d..i"i. l• ,; ai` ,�� K'+� •}., :• •+: :, ::'' 's
. +11 ;.I�. '�i.5 t`q} +G•,+.,.:..!".Yf 'i;f '.
. r'.�h�.�•'j.LL yy �� 2��. r''af� �� K a•ii' �• !'►f,, h'. ]�.: .4. .M1:,.a,' ,i^. i ,f,: •r, 'a, ,i]. }jl ,`. •��."�,�tiT •:T 'I}'•I -'�it'1R" '�r�.�
}'11 i.1 •• 1� f.!3 ,.Sf 'r4' f6 Y7 ;. t .alr •1 ,,: St ,r: ,�'!., +••1;•,' .rw �i''r 'I• +:'''•�' {'..E _.{�, �s'c :•f. �L�� is 1[�j'? F +' _. r. `a 3
�•'3 ,, /• S �• L y;�,[ '}�M.{, 1,' "h �:�. :r :;�+ 'r iiir •r.i: f'.f_+� 1=:i e.�';. �' �•e.i , .%, r� ,++i•'.
V�.t :`, y'• ai y, S,',• �i. .i��' :e ��++ .i•` �'i• ,, i =^r :.�1 ;f�i: rrh +;. ';I, t3` 'i
�. I'7':.'.�; r �, •1i" F i � ' �,. _ .1'°.' i� :'i,. ,1•hi>si' ,q t.
1 �'j/!} S4 li" ,',�;3 '.t' •eli h�!..M, .t tt. �'`J '1'v .� 1 +U f•n .! :�:},..}�'}}•` n�r• r. �''''i y7 •.f. •f.- � !1';.
^�' .'fT '�;'`. '�, a7�. ..J' f(�' k •• !� �1,• R r+i s{��1; ,' q ry •A'. .� �� . ai•, �j r ' r••t .+ •,�� ��� Qlc��i... «'!�i.$L- t.,1 w." .t.i', .�' 'i �i •^J%.� IS:?r•,. .�/'•,^i. 1R !N'f' •;" r'7: ,f'
,'rl. •.'�. 'F '�y M 'i,` :'E �+A' �e g i•r .i.! s .�f .t �1 �t'. •d -.i �+,.•��,'�✓,li�li; -��}}t > !. ..�:7.1Tv: ,I.11Cr.'srt,�+;.f.,.', ;: 1. '•i"�'':3",y.=+ -_� .F}•'i,` y �-�( �.�:, ..
r,): '�': ,i.i i': f� W f , '7 ,a� IiFf gL.► fYlf F "�L:h 'f�A ,1 •' , i i I .!}�... �•^ •ai... �e .wi; j,' J :q;t+ ,7r '
:t,��l� :,ij �{i.f Ik�re� r 'ry, 'vl': •,f��•;. �i.:i `rl• �[iff, •�:,[; f..:�;�� ,�1,:1►�`elE.�?•A:t.e.':.•1'/,:•Q� r 7 si;ll� ~ 1_a�.•,.':'=?:s•:I °�`'S. I �v. tt.I -�.�k.
. �•'i .I, +L` 'i 1 rfy . t,.+., f. . 1 • ' R' s iL
4•j'.P-' . s�.. r . .It' i r,•.$ f 'r^ix.' ' i' trS�.'. ��-' •:+-t 'i' '`�-[.._::i:r ":. . [}# ��i' p; . �. i! 1 k 4 �' .fi:
•�.• ,��. .r :�:='+• .•S�'+f. `• ii. ; a,,•,.�,..y .�` _-.. ;�;i_z y;+.a,.t: �# a.�' �p i�1
`.1' ,� `',�.,a.1" a !x:•f i• �.1.? `�` v.*'-�Y• :a t , .Y i•j};''�,'
t !% "f I`i, r ii: _�tt:'n1'J�Y s� ri".z fir. 4 . T7�/�(y�� a I .. :�: rrw ■, F`
•y�r...�" ;" v ti:: ^N.}_ k :3' .�f•11�.i¢,� •, �',•=.7• I. # r` r {a.v !- _tie' ,k• "'P. •i'. ,a:/,��!
s, l .t s' .i ; • , • .l L•• s '..7•w'g 1. y .Lt : p.. „1.
�'�. -`, .• . _ '•1� /.r,��JJi...4 �-•l1: i. .J'•' f .�a.'# 's' ;,+ ,. Yi. a •. ,1S- F�.
'rS:�,'. '.r t,' ,_•�•` d •'�'..••,7. Cy'�'r +•+'i Syr` - .. k.' :.al�i /�. A••,i� �`. .-./,.YD•'�}''a
.47
+� t t� -�,', 's•�+'w i,..1-' 7�i ��+�■i �.. ,r,^'s; yS1Jr. f � ",�� Cil��l'ir•� I (,�' A�,u
` att '' ", . .ls �' ' �! t 1= . a'��:J i'+ 1�; •. ,y e. I[ aY ,� j 7 ` i a _%I(' !L -•. '• f.
7, +� ..1 yro�r 'r 4G � ,E i � r } 2'g' .EI • j,s rs..' � {l.�Y •',.�- y�
:a + .► i-'-rt'- Y.CTT.I^ :i•` ,. .�.: 1�t.�'s�,,,�1 }�";�,/�'��� ..fi•eCl; '��:. •_.*�• 'ti 1
�:, ,,� �i.`ti a.#� F:;���'1,''S' ',,�'.�"'ti�i'.:�'��fW��lyr',r• � '```fir-�.T
s •' � •.t'• vl�i f � w.. i °� k;rtJ: ' �i, rY�.. r �'1 � •:.
- ^, ,!'�s a }t e•!�� •,F,^ily�•I�..i+'
` 'wy' ••I +li'r7 <Ly<f }�T '`i �•I'��-•�.r '=r �•�q �1 • t .='�•..
33 ^7 n-}�� � !+ I�saf ,A a".+, •� A7. a t � G � _',f it .i '•, •jar' •y/
71; + r� 'h�+f��i�'i�t,'? •''� 1' �'t� ��•fs�'ti�i :Y ��. �r�tj tT�y' :ly,. °�' .R1 Y'�.+ fr�•_t', -a •+' �.
sA

ANIMAL WASTE UTILIZATION PLAN
AM A0%
`i=oduceru ' •> RICAARD WHITFIELD RECEIVED IDENRIDWQ
AQi1fFF -PRnTFr,T1r M SECTION
Location.:. • Y 1670O'KENAN .WEEKS RD. AUG 2
NEWTON GROVE NC 28366
5 Z��g
Telephone: (910) !iy4•-1357 RECT,jED
'Type Operation' . Existing Fepder to Finish 1.wineAUG
-Nrmber 4bf_-Animala:a° = `' 1200. 00 hogs OEhiR-FA1' ET LL( REGIDiVALOFACE
(Design CapAcity)• ��'?
f4
STORAGE STRUCTURE ` Aaerobic Waste Treatment Lagoon
' X Y; jMe
APPLICATION METOD Irrigation
f. The, wastie ;from-youi animal facility must be land applied at a
spe�ifi%d " `at�'t o prevent pollution of surface water and/or
groundwater T,e�plant nutrients in the animal waste should be used
to reduce. Ale amount of commercial fertilizer required for the crops
¢in the fib's •where the waste is to be applied.
This waste utiliz'ation�.plan�uses nitrogen as the limiting nutrient.
Waste -•should • �amalyzed' before each application cycle. Annual soil
tests dare stxon � ,.encoura ed so that all plant nutrients can be
g. y g
ba'`ianaed far rea,'kf "stic yields of the crop to be grown.
.p.;
Several facto47s are.,import'ant in implementing your waste utilization
plan in order. ,,to maximize the fertilizer value of the waste and to
eAstire tha,t� it'�d`s applied in an environmentally safe manner:
1.^ A ways apply waste based on the needs of the crop to be
grown_ and the nutrient content of the waste. Do not apply
more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
'rates,,1eaching potentials, cation exchange capacities, and
available water holding capacities.
3.• Normally waste shall be applied to land eroding at less than
5 tons per afcre:per year. Waste may be applied to land
eroding at,5 ors.more tons -per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on saturated soils, when it is raining,
or when the surface is frozen. Either of these conditions
may result ,.in -,runoff to surf` ee waters which is not allowed
under DWQ 'e-4ulat ions .. '
` `'' Page: 1

ANIMAL WASTE UTILIZATION PLAN
5. -Wind conditions should 'also be considered to avoid drift and
downwind odor problems.
6. To maximize the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more than 30
days prior to plantirp a crop or forages breaking dormancy.
Injec-ting the waste or disking will conserve nutrients and
redudd odor problems.
This plan',!is based-rern the waste application method shown above. If
you choose to"chd'rige methods in the future, you need to revise this
plan. Nutrient lg_,vels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient4 content for this type. '.of facility. Acreage
requirements should be based on the waste analysis report from your
waste management facility. In some cases you may want to have plant
analysis made;%,:whi'eh`could allow additional waste to be applied.
Provisions sha•l�,l'�be"made for the area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must }bii'applied to maintain pH in the optimum range for specific
crop product' on'
Of
This waste uti.lization plan, if carried out, meets the requirements
for campliancc�,'tiwi.�th"15A NCAC 2H .0217 adopted by the Environmental
Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
1200 hbgs x 1.`9":.;tons waste/hogs/year = 2280 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
1200 hogs x 2.3 lbs PAN/hogs/year = 2760 lbs. PAN/year
Applying the above amount of waste is a big job. You should plan time
and have appropriate equipment to apply the waste in a timely manner. .
The following acreage will be needed for waste application based on
the crop to be grown „,soil type and surface application.
Y � f
Page: 2
ati

. 1
ANIMAL WASTE UTILIZATION -PLAN
4 ti�
TABLE l.: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
-DETERMINING PHASE
CODE
AW N
PER.
ACRES
AW N
PER AC
AC
USED
----
or
------
APPLY
RESID.
APPLIi
METH
N
TIME
C SB
5761
1
Ra },
110
117.7
0
1.24
145.94.
I
MAR-JU.
5781
Ra
120
_ .24
rl48.8SEP-AP
1-1
1
IT
150
to
5781
R�k N-
SBDC
133.0
1132
0
1.24
163.68
I
JUN -JkU
a
5781
2
Q vA,
C SB
125.0
136.25
0
1.90
r258.8-7I
1
- JU
5781
GoA `,*:
W
0
1-2
1
I I
160.0
1144
11.90
1273.6
SEP-AF
57B1
2
SBDC
35.0
140
0
266
jGoA
I
11.90
JUN�t;.,_
5781
3
GoAF.;.;Y,
C SB
125.0
136.25
0
12.06
MAR - J[
5781
0
1-3
jGoA.
JW
I
160.0
1144
12.06
1296.6t
SEP-Al
5781
3
SBDC
0
0
2.06
288.4
jGoA
135.0
114
!
SG.1- f
5781
4
C SB
110
0
242.4r
lRa
x
13-17.7
12.06
MAR - J3
5781
'4
0
247.2
jRa
JW
I
150
1120
12.06
ISEP-A
5781
4
lRa
SBDC
P3. 0
0
271.9.
I
1132
12.06
,J[rN
pw
5781
5
lRa
C SB
110
0
1.03
1 1.2
I
1117.7
1 MAR-J
--A
5781
-5
JR1 :.'
W
li
50
12.0
0,
1.03
F123.6
I I
I
I
ISEP-A
Page: 3

ANIMAL WASTE UTILIZATION.PLAN
5781 T lRa SBDC 133.0 1132
END
I
1.03 1135-96
JUN - AUC
TOTAL 13264.9S
- Indicates that this field is being overseeded (i.e. interplanted)
or winter annuals follow summer annuals.
NOTE: The applicator is cautioned that P and K may be over applied
while meeting the N requirements. In the future, regulations may
require farmers in some parts of North Carolina to have a
rtrient ffiariagement plan that addresses all nutrients. This plan
c ty addresses nitrogen.
'I
i
ti Page: 4

ANIMAL WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
See required specification 2_)
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
__--
or
-------
APPLY
RESID.
APPLIC
METH
N
TIME
END
TOTAL10
Indicates that this field is being overseeded (i.e. interplanted) or
winter annuals follow summer annuals.
** Acreage figures may exceed total acreage in fields due to
overseeding-..�
* lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and 2 above_
CROP CODE
CROP
UNITS
PER UNIT
C/SB
CORN AFTER SOYBEANS
BUSHELS
1.09
SBDC
SOYBEANS DC
BUSHELS
4
W
WHEAT
BUSHELS
2.4
TOTALS FROM TABLES 1 AND 2
ACRES LBS AW iN USED
TABLE 1 16.58 3264.991
r --
Page: 5

ANIMAL WASTE UTILIZATION PLAN
TABLE 2
0 0
TOTAL l 16.58 3264.991
*** BALANCE-504.991
-------------------
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.
1
Page: 6

ANIMAL'WASTE UTILIZATION, PLAN
*** This number must be less than or equal to 0 in order to fully
utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffers, filter strips along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than the
acres shown: -.in the tables.
See attached map showing the fields to be used for the utilization of
animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient
rich and will require precautionary measures to prevent over application
of nutrients or other elements. Your production facility will produce
approximately 444 pounds of plant available nitrogen per year in the
sludge.
If you remove the sludge every 5 years, you will have approximately 2220
pounds of PAN to utilize. Assuming you apply this PAN to hybrid
bermudagrass hayland at the rate of 300 pounds of nitrogen per acre, you
will need 7.4 acre's of.land_ If you apply the sludge to corn at
the rate of 125.p6unds of nitrogen per acre, you will need 17.76 acres
of land. Please .be aware that these are only estimates of the PAN and
land needed. Actual requirements could vary by 25% depending on your
sludge waste analysis, soil types, realistic yields, and application
methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the
soil at the time of irrigation such that runoff or ponding occurs. This
rate is limited by initial soil moisture content, soil structure, soil
texture, water droplet size, and organic solids. The application amount
should not exceed the available water holding capacity of the soil at the
time of irrigation nor shoul7d the plant available nitrogen applied exceed
the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables l.-'and'2. Failure to apply the recommended rates and
Page: 7

ANIMAL WASTE UTILIZATION PLAN
amounts of nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application
rates and amounts.
Tract
Field
Soil Type
Crop
Application Rate
(in/hr)
Applic. Amount
(inches)
5781
1
Ra
C/SB
0.35
*2.35
5781
1
Ra
SBDC
0.35
*1.90
5781
2
GoA
C/SB
0.40
*2.35
5781
2
GoA
SBDC
0.40'
*1.70
5781
3
GoA
C/SBT
0.40
*2.35
5781
3
GoA
SBDC
C SS
0.40
*1.70
5781
4
Ra
0.35
*2.35
5781
4
Ra
SBDC
C SB
0.35
*1.90
5781
5
Ra
0.35
*2.35
5781
5
Ra'
SBDC
0.35
*1.90
5781
Ra
W
0.35
*1.90
5781
'2
GoA
W
0.40
*1.70
5781
r3
GoA
W
0.40
*1.70
5781
`4
Ra
W
0.35
*1.90
5781
-5
Ra
W
0.35
*1.90
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. in many situations, the application amount shown cannot
be applied because ofE'the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Page: 8

ANIMAL [BASTE UTILIZATION .PLAN
Your facility is designed for 140.00 da of temporary storage and the
temporary storage must be remove on t e average of once every
4.66666666667 months. In no instance should the volume of the waste
be stored in your structure be within the 25 year 24 hour storm
storage or one foot of freeboard except in the event of the 25 year 24
hour storm.
It is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply the
correct rates to the acres shown in Tables 1 and 2. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may
make this plan invalid.
Call your technical specialist after you receive the waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate prior to applying the waste.
NARRATIVE OF OPERATION
� ;� fable.. r 't a o� o,c�tt►.a\ a�ceaow.,e. , -C�ns s
r-ce. S CaM�u��CQ C`
Vq�
Page: 9

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste- If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per -Acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
5. Odors can be,•_reduced by injecting the waste or disking after
waste application. Waste 'should not be applied when there is
danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, the waste may be -'broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
S. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on aftively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be considered.
Page: 10

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. waste nutrient loading rates on these soils should be
.held to a minimum and a -suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips).
12.. Animal waste shall not be applied closer than 100 feet to
wells.
13. Animal.waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged into surface waters,
drainageways'; 'or wetlands by a discharge or by over -spraying.
Animal waste,may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly into water courses,
and on other grassed waterways, waste shall.be applied at
agronomic rates in'.a manner,,that causes no runoff or drift from
the site. ;;. .
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs,'and
other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or'discharge.;
Page: 11

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
18. If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all -waste treatment lagoons. Pumping shall be managed to
.maintain the liquid level between the markers. A marker will
be5required, to mark the maximum storage volume for waste
storage ponds.
22.*Wagt_e shall be tested within 60 days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element. Zinc and copper levels in the soils shall be
monitored '4nid`.`alternative crop sites shall be used when these
metals.approach excessive levels. pH shall be adjusted for
optimum`crop'production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be
maintained for five (5) years.
23. Dead animals will bex.dispoed of in a manner that meets North
Carolina regul at ions :a
r
Page: 12

ANIMAL WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of FarAi: RICHARD WHITFIELD FARM
Owner/Manager Agreement
i (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above- I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new
facilities>,will require a new certification to be submitted to the
North Carolina Division of Water Quality (NCDWQ) before the new
animals are stocked. I (we) also understand that there must be no
discharge of animal waste from this system to'surface waters of the
state-;frgm..a storm event -less severe than the 25-year, 24-hour
storiThe approved plan will be filed on -site at the farm office
and -'.'a e office of the local Soil and Water Conservation District
and,,.' e,available for review by NCDWQ upon request.
Name of Facility Owner: RICHARD WHITFIELD
(Please priest)
Signature: 4L ` Date:
Name of MiAgger (if different from owner) :
Signature:
Date:
Name of Person Prepa `g Phan:,, (Please print)Wil$on Spencer
Affiliation:NRCS Phi
Address (Agency): 84 County GDmplex Rd.
Clinton NC 28328
ti ry
Signature. - Date.
y
Page: 13

I

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
October 1, 2004
William T. Herring
Pork Chop Hill Finishing #6
PO Box 300
Newton Grove NC 28366
Alan W. Klimek, P. E-. Director
Division of Water Quality
RECEIVED
OENR - FAYETTEMLLE RIEGdONAL OFRGE
Subject: Certificate of Coverage No. AWS820488
Pork Chop Hill Finishing #6
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
Dear William T. Herring:
On dune 11, 2004, the North Carolina Division of Water Quality (Division) issued a revised State General
Permit for swine facilities. The General Permit was issued in accordance with the directive of Senate Bill
733 (Session Law 2003-28).
In accordance with your application received on February 18, 2003 and in accordance with the directive
of Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to William
T. Herring, authorizing the operation of the subject animal waste collection, treatment, storage and land
application system in accordance with General Permit AWG100000. The issuance of this COC
supersedes and terminates your previous COC Number AWS820488 which expires October 1, 2004.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Pork Chop Hill Finishing #6, located in Sampson County, with an animal
capacity of no greater than an annual average of 735 Feeder to Finish swine and the application to land
as specified in the facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to
Wean or Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are
unneccessary, they may be replaced by an equivalent number of sows. Any of the sows may be replaced
by gilts at a rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Since this is a revised State
General Permit, it contains new requirements in addition to most of the conditions contained in the
previous State General Permit. Enclosed for your convenience is a package containing the new and
revised forms used for record keeping and reporting. Please pay careful attention to the record keeping
and monitoring conditions in this permit.
Aquifer Protection Section - Animal Feeding Operations Unit
1636 Mail Service Center, Raleigh, North Carolina 27699-1638
Phone: [phone] I FAX: [phone] Internet: h2o.enr,state.mus
An Equal Opportunity/Affirmative Action Employer — 50% Recycled110% Post Consumer Paper
Nne
orthCarolina
Natmnallff

If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 2H .0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per MRCS standards a 100 foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration_
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a coemty covered by our Fayetteville Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Duane Leith at [phone].
Sincerely,
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
Fayetteville Regional Office, Aquifer Protection Section
Sampson County Health Department
Sampson County Soil and Water Conservation District
Permit File AWS820488
APS Central Files

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
Michael F. Easley, Governor
Sherri Evans -Stanton, Acting Secretary
Kerr T. Stevens, Director
William T. Herring
Pork Chop Hill Finishing #6
PO Box 300
Newton Grove NC 28366
Dear William T. Herring:
NCDENFt
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
January 19, 2001 U L� �
Subject: Certificate of Coverage No. AWS820488
Pork Chop Hill Finishing #6
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
In accordance with your application received on December 12, 2000, we are forwarding this
Certificate of Coverage (COC) issued to William T. Herring, authorizing the operation of the subject
animal waste collection, treatment, storage and land application system in accordance with General
Permit AWG100000. This approval shall consist of the operation of this system including, but not
limited to, the management of animal waste from the Pork Chop Hill Finishing #6, located in Sampson
County, with an animal capacity of no greater than 735 Feeder to Finish and the application to land as -
specified in the Certified Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations
as specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
The facility's CAWMP meets all requirements in place at the time of certification. However, it
appears that the irrigation system on site may not adequately cover all acreage listed in the Waste
Utilization Plan. The owner should address this inconsistency as soon as possible.
Please be advised that any violation of the terms and conditions specified in this COC, the General
Permit or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS
143-215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Certificate of Coverage AWS820488
Pork Chop Hill Finishing #6
Page 2
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This
request shall be made within 30 days of notification by the Division.
This COC is not automatically transferable. A name/ownership change application must be
submitted to the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the
right to apply for an individual non -discharge permit by contacting the engineer listed below for
information on this process. Unless such a request is made within 30 days, this COC shall be final and
binding.
The subject farm is located in the Fayetteville Regional Office. The Regional Office Water
Quality Staff may be reached at [phone]. If you need additional information concerning this
COC or the General Permit, please contact JR Joshi at [phone] ext. 363.
cc: (Certificate of Coverage only for all cc's)
Sampson County Health Department
Fayetteville -Regional Offce; Wa""ter Quality -Section
Sampson County Soil and Water Conservation District
Permit File
NDPU Files

RECEIVED
Animal Waste Management Plan Certification
or
a
- + oft- , � , Wit.t l(M
Hera! information: k � Q schargs Compliance lrnf
Name of Farm: ar _ _'it► `nS i 5 �e� G_ _ _ [� —Facility 1,o:
O,�x•mr(s) Name. �1 _i �+.tA- T ��>r��L1A � Phone No: 9lQ- 3 � Sf-ozC9
A'lailina Address: f �3�X 3dD Jl� ti r3VC h] G
Farm Location: County Farm is located in: '511-1.4:sax
Latitude and Longitude: 35 n IZ' Si ' z 2!1 " Integrator: -bA4
Please attach a copy of a county road map with location identified and describe below (Be specific: road
names, directions, milepost, etc.): ! ,� k 1470 f . A 4uw- C[_; 7L sS
�a Jyt Tu fir. sx S� 1 DD _ +-An, p � _ s �r�- L
Overation Descrivtion:
Type of Swine A'o. of Animals
D Wean to Feeder
weeder to Finish
O Farrow to Wean
D Farrow to Feeder
❑ Farrow to Finish
0 Gilts
D Boars
Type of Poultry
Laver
Pullers
No_ ofAnimais
Type of Carrie
• Dairy
7 Beef
No. of . �nhnais
Other Type of Livesrock--- A'umber of Animals:
Acreage Available for Application: J`Y + 5— Required Acreage: S
Number of Lagoons / Storage Ponds: i Total Capacity: Cubic Feet (ft3)
Are subsurface drains present on the farm: YES �NO (please circle one)
If YES: are subsurface drains present in the area of the LAGOON or SPRAY FIELD (please circle one)
Owner / Manager Agreement
I (we) verify that all the above information is correct and will be updated upon changing_ I (we) understand the operation
and maintenance procedures established in the approved animal waste management plan for the farm named above and will
implement these procedures. I (we) know that any expansion to the existing design capacity of the waste treatment and
storage system or construction of new facilities will require a new certification to be submitted to the Division of
Environmental Management before the new animals are stocked. I (we) understand that there must be no discharge of
animal waste from the storage or application system to surface waters of the state either directly through a man-made
conveyance or from a storm event less severe than the 25-year, 24-bour storm and there must not be run-off from the
application of animal waste. I (we) understand that run-off of pollutants from lounging and heavy use areas must be
minimized using technical standards developed by the Natural Resources Conservation Service. The approved plan will be
filed at the farm.'and at the office of the local Soil and Water Conservation District I (we) know that any modification
must be approved by a technical specialist and submitted to the Soil and Water Conservation District prior to
implementation. A change in land ownership requires written notification to DEM or a new certification (if the approved
plan is changed) within 60 days of a title transfer.
Name of Land O
i
Signatare:— 2
Name of Managc
AWC -- August I,
t_ from
it
er
Dater _ I -
Date:

It
Technical Specialist Certification
I As a technical specialist designated by the North Carolina Soil and Water Conservation Cemn fission pursuant to 15A
NCAC .0005, I certify that the animal waste management system for the farm named above las an animal waste
management plan that meets or exceeds standards and specifications of the Division of Environmental Management
(DELM) as specified in 15A NCAC 2Ii0217 and the USDA -Natural Resources Conservation Service (MRCS) and/or the
North Carolina Soil and Water Conservation Commission pennant to 15A NCAC 21-1A217 and 15A NCAC 6F .OQol-
.0005. The following elements are included in the plan as applicable. While each category de Donates a technical specialist
who may sign each ce.dficadon (SD. SL WLTP, RC, 1). the technical specialist should only certify parts for which they are
technically competent.
IL Certification of Design
A) Collection. Storage_ Treatment System
Check the appropricre box
O Existinz facility wirhont retxoft (SD or WUP)
Storage volume' is adequate for operidon rapacity; storage capability consistent with _waste utilization
requirements.
0 New. expanded or retrofitted facility (SD)
Animal waste storage and treatment structures, such as but not limited to collection systems, lagoons and ponds,
have been desia-ned to meet or exceed the minimum standards and specifications.
Name of Technical Specialist (Please Print):
Address (Azency): S
Signature:
tr
ate Work Completed:
?232-3 PhoneNo.:
B) Land Annlication Site (W-Up) V
Tne plan provides for minimum separations (buffers); adequate amount of land for waste utilization; chosen crop is
suitable for waste management; hydraulic and nutrient Ioading rates.
Name of Technical Specialist (Please Print):
[ n w �
Affihatio
Address (Agency);
Sianarnre:
C) Runoff Controls from Exterior Lots
Check the aDDrODriare box
Cd-�Facihty wiuhour exterior lots (SD or W P or RC)
This facility does not contain any exterior lots.
to Work Completed: %a2z -
2�3z Phone vo.: — 79 6
Date:_ 1-�I--5,--yi7
'aJ Facility with exterior lots (RC)
Methods to tninimie the rLm off of pollutants from lounging and heavy use areas have been designed in
accordance with technical standards develoved by tiRCS.
.Name of Technical Specialist (Please P-:nt):
.i n c
Ari]iati
Address (Aaency):8",
Sisnaeure:
AWC -- :august 1, 1997
ork Completed:
� Prone No.:_J^
Date: L

D). Application and Handling Equipment
Check the appropriate box
_Y_ isdna or ex;2andin ; asilin with existing waste _g=1icatian eouipment (WUP or 1)
Animal waste application equipment specified in the plan has been either field calibrated or evaluated in
accordance w7tb existing design charts and tables and is able to apply waste as necessary to accommodate the
waste management plan: (existing application equipment can cover the area required by the plan at rates not to
exceed either the specified hydraulic or nutrient loading rates, a schedule for timing of applications has been
established; required buffers can be maintained and calibration and adjustment guidance are contained as part of
the plan).
J New, e2jpanded. or existing facility-!LhOUt exis 'na waste application equipment for sprav irrigation. (I)
Animal waste application equipment specified in the plan has been designed to apply waste as necessary to
accommodate the waste management plan; (proposed application equipment can cover the area required by the
plan at rates not to exceed either the specified hydraulic or nutrient loading rates; a schedule for timing of
applications has been established; required buffers can be maintained; calibration and adjustment guidance are
contained as part of the plan).
New, expanded, or existing fagilirywithout ez 'ng a-aste_arnlicad n equipment for land Spreadir.b_ not using
c v ini n (WUP or I)
Animal waste application equipment specified in the plan has been selected to apply waste as necessary to
accommodate the waste management plan; (proposed application equipment can cover the area required by the
plait at rates not to exceed either the specified hydraulic or nutrient loading rates; a schedule for timing of
applications has been established; required buffers can be maintained; calibration and adjustment guidance are
contained as part of the plan).
Name of Technical Specialist (Please P-int):_ . , , _.eu cc.,
Affiliation Al&-:5 Date Work Completed: ;�
Address (Agency): Cw-A �?n! , AJL Z23 2-2 Phone No.: 7TOf�
Signature: Date:
E) Odor Control. Insect Control. Mortality Management and Emeirgenev Action Plan (SD.
Sl._NVUP. RC or I)
The waste management plan for this facility includes a Waste Management Odor Control Checklist. an Insect
Control Checklist, a Mortality Management Cbecklist and an Emergency Action Plan. Sources of both odors and
insects have been evaluated with respect to this site and Best Management Practices to Minimize Odors and Best
Management Practices to Control Insects have been selected and included in the waste management plan. Both the
Mortalty Management Plan and the Emergency Action are complete and can be implemented by this facility.
1
Name of Technical Specialist (Please Print)
Affiliation IJrM__
Address (Agency):,
Signature:
e--
1a
ate Work Completed: p 7
ZJ3? XPhone No.. 59,Z ` 7 l 63
F) Written Notice of New or Expandini S Aine Farm
The following signature block is only to be used for new or expanding swine farms that begin construction after Julie
21, 1996. ff the facility was built before June 21, 1996, when was it constructed or last
expanded
I (we) certify that I (we) have attempted to contact by cerdfied mail all adjoining property owners and all property owners
who own property located across a public road, street, or highway from this new or expanding swine farm. The notice was
in compliance with the requirements of NCGS 106-805. A copy of the notice and a list of the property owners notified is
attache,d
Name of Land Owner:
Signature:
Date:
Name of Manager (if different from owner):
Signature: Date:
AWC -- August 1, 1997 3

f
III, Certification of Installation
A) Collection_._ Storage. Treatment Installation
New. expanded or retrofitted facility (SI)
Animal waste storage and treatment structures, such as but not limited to lagoons and ponds, have been installed
in accordance with the approved plan to meet or exceed the minimum standards and specifications -
For existing facilities without retrofits, no cert&ation is necessary.
Name of Technical Specialist (Please Print).
Affiliation Date Work Completed:
Address (Agency): Phone No.:
Signature: Date:
s
B) Land A lication Site (WUP)
Check the ppropriate box - -
The cropping system is in lace on all land as specified in the animal waste management plan.
PP .. Y P P ..
u Conditional Approval: all required land as speed in the plan is cleared for planting; the cropping system
as specified in the waste utilization plan has not been established and the owner has committed to establish the
vegetation as specified in the plan by (monrhidayfyear); the proposed cover crop is
appropriate for compliance with the wastevtilization plan.
Also check this box if appropriate
if the cropping system as specified in the plan can not be established on newly cleared land within 34 days
of this certification, the owner has committed to establish an interim crop for erosion control;
Name of Technical Specialist (Please Print):
Affiliation AVC5
Address (Agency):
ate Work Completed: !P2 -
�3Ly Phone No.: 59� - 7� G, 3
Date- I) —
This following signature block is only to be used when the box, for conditional approval in III. B
above has been checked.
I (we) certify that I (we) have committed to establish the cropping system as specified in my (our) waste utilization plan,
and if appropriate to establish the interim crop for erosion control, and will submit to DF—M a verification of completion
from a Technical Specialist within 15 calendar days following the date specified in the conditional certification. I (we)
realize that failure to submit this verification is a violation of the waste management plan and will subject me (us) to an
enforcement action from DE-M.
Name of Land Owner:
Signature: Date:
Name of Manager (if different from owner):
Signature: Date:
,• WC -- August 1, 1997 4

C) Runoff Controls from Exterior Lots (RC)
Facility with exterior Iots
Methods to minimize the run off of pollutants from lounging and heavy use areas have been installed as specified
in the plan.
For facilities without exterior lots, no certification is necessary.
Name of Technical Specialist (Please Print):
Affiliation Date Work Completed:
Address (Agency): Phone No.:
Signature: Date:
D) Application and Handling Equipment installation (NNTT or n
Check the �ay�ropriate block
3 .Animal waste application and handling equipment speed in the plan is on site and ready for use;
calibration and adjustment materials have been prodded to the owners and are contained as part of the plan.
J Animal waste application and handling equipment specified in the plan has not been installed but the owner
has proposed leasing or third party application and has provided a signed contract: equipment specified in
the contract agrees with the requirements of the plan; required buffers can be maintained; calibration and
adjustment guidance have been provided to the owners and are contained as part of the plan.
J Conditional approval: Animal waste application and handling equipment specified in the plan has
been purchased and will be on site and installed by (month/day/year); there is adequate
al
storage to hold the waste until the equipment is installed and until the waste can be land applied in
accordance with the cropping system contained in the plan; and calibration and adjustment guidance have
been provided to the owners and are contained as part of the ply,
Name of Technical Specialist (Please Print):.
Affiliation 14AC5
Address (Agency):
Sienature:T�
Work Completed: /Z -/- 9 Z
32_Y Phone No.: a2 -7S6 3
Date: q %
The following signature block is only to be used when the box for conditional approval in III D
above has been checked.
I (we) certify that I (we) have committed to purchase the animal waste application and handling equipment as
specified in my (our) waste management plan and will submit to DEM a verification of delivery and installation
from a Technical Specialist within 15 calendar days following the date specified in the conditional certification. I
(we) realize that failure to submit this verification is a violation of the waste management plan and will subject me
(us) to an enforcement action from DEM.
Name of Land Owner:
Signature: Date:
Name of Manager (if different from owner):
Signature: Date:
E) Odor Control. Insect Control and Mortality_ Management_ (SD. SI. WU"P. RC or
Methods to control odors and insects as specified in the Plan have been installed and are operational_ The
mortality management system as specified in the PIan has air bee�n�ijns_ led and is operational.
Name of Technical Specialist (Please Print): ?'
Address (Agency):
AWC -- August 1, 1997 V 5
ate Work
-1-9
ze 3 Z$ Phone No.:52.-- 7 9 G 3
Date: / 2 S` '±7

Please return the completed form to the Division of Water Quality at the following address.,
Department of Environment, Health, and Natural Resources
Division Of Water Quality
Non -Discharge Branch, Compliance Unit
P.O. Box 29535
Raleigh, NC 27626-0535
Please also remember to submit a copy of this form along with the complete Animal Waste
Management Plan to the local Soil and Water Conservation District Office arid to keep a copy
in your files with your Animal Waste Management Plan-
3
AWC -- August ], 1997 6

State of North Carolina RECEIVED
Department of Environment and Natural ResoureeJU t 2 2000
Division of Water Quality WATER QlIALtTY SECTION
Non -Discharge Permit Application Form
OftpPeftfing
(THIS FORM MA Y BE PHOTOCOPIED FOR USE AS AN ORIGINA
General Permit - Existing Animal Waste Operations
The following questions have been completed utilizing information on file with the Division. Please
review the information for completeness and make any corrections that are appropriate. If a
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
1_ GENERAL LNFORI XTION:
1.1 Facility Name: Pork Chop Hill Finishing #6 _
1.2 Print Land Owner's name: William T. Herrine
1.3 Maiiins address: PO Box 300
City. State. Newton Grove NC Zip: 28366
Telephone ?Number (include area code): 910-594-0219
I.; County where facility is located: Satnpson
L5 Facility Location (Directions from nearest major highway_ Please include SR numbers for state roads. Please include a copy
of a county road map with the location of the farm identified): Farm location: 1 mile west of Rt. 701 off S.R. # 1800
1.6 Print Farm.Manager's name (if different from Land Owner): TDM Farms Inc_
1.7 Lessee's I Integrator's name (if applicable; please circle which type is listed): Newton Grove Grain and Feed
1.8 Date Facility Originally Began Operation: 1/1/1974 _
1.9 Date(s) of Facility Expansion(s) (if applicable):
2. OPERATION INFORINUTION:
2.1 Facility No.: 8''_ (county number); 88 (facility number).
?? Operation Description: Swine operation
Feeder to Finish
735- Certified Design Capacity
Is the above information correct? 7✓ yes: Flno. If no. correct below using the design capacity of the facility
The "No, of Animals- should be the maximum number for which the waste management structures were desiened.
Type of Swine No. of Animals Tvr)e of Poultry No_ of Animals Type of Cattle No. of .animals
0 Wean to Feeder 0 Laver 0 Dairy
0 Feeder to Finish 0 Non -Layer 0 Beef
0 Farrow to Wean (# sow) 0 Turkey
0 Farrow to Feeder (s sow)
0 Farrow to Finish (n sow)
Other Tvpe of Livestock on the farm: No. of Animals.
vnur [• e wn-r_-P. 7/7199 Pa„e 1 of 4 82 - 488

2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
System): 5-45 : Required Acreage (as listed in the AWMP): 5.2
2.4 Number of lagoon 1 storage ponds (circle which is applicable):
2.5 Are subsurface drains present within 100' of any of the application fields? YES or N (please circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES or NO (please circle one)
2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act. N'RCS Standards, etc.) (Swine Only)
,! -ES or NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited? '7 — 7
What was the date that this facility's land application areas were sited? I ' d q ` i y
3. REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
A licants Initials
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations:
- v 3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied:
V 3-3 Two copies of the entire Certified Animal Waste Management Plan (CAW1�1P). If the facility
does not have a CAWIVIP. it must be completed prior to submittal of a general permit application
for animal waste operations.
The CAWAIP must include the following components. Some of these camponentrs mcn• not
have been required or the time the facifirr is -as certified but should be added to the
Cal WX/P for permitting purposes:
✓3.3.1 The Waste utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
✓3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation.
injection. etc.)
✓3.3.3 A map of every field used for land application.
✓ 3.3.4 The soil series present on every Iand appiication field.
t -3.3.5 The crops grown on every land application field.
✓3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
.�3.33 The PAN applied to every land application field.
✓3.3.8 The waste application windows for every crop utilized in the WGP.
A.3.9 The required MRCS Standard specifications.
--3.3.10 A site schematic-
3.3.11 Emergency Action Plan.
3.3.13 Insect Control Checklist with chosen best management practices noted.
3 3.13 Odor Control Checklist with chosen best management practices noted,
V3.3.14 vlortality Control Checklist with the selected method noted.
v,.3.15 Lagoon/storage pond capacity documentation (design. calculations. etc-). Please be
sure to include any site evaluations. wetland determinations, or hazard classifications
that may be applicable to your facility.
✓3.3.16 Operation and Maintenance Plan.
If your CA%NtiIP includes any components not shown on this list, please include the
additional components with your submittal.
�/ ).,)-I �-
FORM: AWn_(;_F 7n199 Paae 2 of 4 82 - 488

Facility Number: 82 - 488
Facility Name: Pork Chop Hill Finishing #6
4. APPLICANT'S CERTIFICATION:
I, _ }'Jlf r 1 �! 4w�, - 1 f r�+Jt _ _ 1 _ ^ (Land Owner's name listed in question 1.2). attest that
this application for bf «o �'� i 11 4 L- (Facility name listed in question 1.1 )
has been reviewed by me and is ac urate and complete to tl4e best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be returned to ri as' omplet
Sigrtature Date V/�?. G O
a- MANAGER'S CERTIFICATION: (complete only if different from the Land Owner)
I,
(Manaser's name listed in question 1.6), attest that this
application for (Facility name listed in question I _ I )
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be returned as incomplete.
Signature
Date
THE COMPLETED APPLICATION PACKAGE. INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE, FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERVIITTING UNIT
1617 INMIL SERVICE CENTER
RALEIGH, NORTH C AROLINA 27699-1617
TELEPHONE NUN BER: [phone]
FAX NUMBER: [phone]
RECEIVED
AU1 2 zoo
WAM QUALITY SECTION
Narlasolop pemitlli v
1W0R ivt- AWO-G-E 7/7199 Page 3 of 4 82 - 488

Dn-ISiO- OF WATER QL.k= REGIONLkL ox:-TMS (3J98)
NC 2SK-1
51:i =K3
Cam^• r`L. =
pzik
Ciy
v.-Alood
NC -
r?0) rg.i t1
=s= vl?
77 1-*M
aT. i�x
; Z r
SC r 6_r 9
s75-3 i 16
Bcmon
B^t
T.-0:.: , .
c=m6=
Minim
(:!Nowrl
Px=-Il=
G-2v=
V.O,---': _ RtZ:" = ill� S 4-sS;
C--wba
R2,wa=
C'^�rv. * �'
S�tv -
tZ.4G Yr Q Scti�s�
3$0
1Xi-;..'4C 2 rr i 11
o-, 19) 57 1-4—/Jo
- = (9? 19) 3-3 70 2
V==
_ -7
S3S45
= (:10) 350-2Z4
Cry 0=:-;
r:

\\ •, �.I _•''u,, .I,;,;: .y `•••_y't u ,r; w .'I7./}•' `+ •, '; , �I 2 / `Pt
' • ,��,��i •.oil
7 \• r'.«.,,,.+ L° �r nr @ a9 .I :4€ r5 t °r #+ ,' /' 1
1 '',,q `,. , ;,. wa+.,;t �- t ' ` F1 � t ' � r :f • I � rl f ..I ••I
X�\=i '.�• ,�.. ,t+ .� °``� : r.' Fr r j 1;� u � sit � r .. '� �' ,;, ., . • 1
'i� _ �; : r. a ��xr`a. ! � ° ~� � ! €�.+. ��A 4: 'i � `'`*n„f � ` •* �`++•
_ \ : y.,..+py ::yy h 4Y.+Rr,. ! t � � °`y'. 3] '• i �' � ��'. rr •4 � a ni •+ +� �S t ° � r rr I F1 + " 4 t { ' ,
.'+, t =1 !:i L { :� �r,� ��D +° __ � r �,r• r4 �� • a �'. � a`` > =� J' •'+. 11 \°.r'. i �.
! �++ a a,y + ?f,•. fir,: .`� �! ��+ ��
• . � / o .a�' ;�� f p �� � r ',� � 'i . r S! � .�• �+ ' t ; � •_.1 `�r� � /�r .r r ',f � n
+ � II -' � .,.�` • l �Mw�+ ':1 p• � rj �: rr � � ro"I .r•rr �r �r �;:`k�. �"t' :+J . • .�a
;� �; r `� ' •nria. • .++`` ;� % J � �� '+ • � � • � !�F'r° � &I 9 •� r''°hcr 4 � � � � rr �� Lf;y° I ''1�i�;1 � `` � � ,`,
• 1. ngpYn .' d /S �.>''• ° • `� �• r • l P o` f Ir.or °,nY I ua+j_ `Q , F
rf i { ` t� / n �� ' e. ♦ {` q 6 4 , . t i F ( t .., •° 'h r
1 _ � r f � � ^_4 ;•. � �O. a e"+.,� � '�- g r r• i !''r � �, � �' r i {l S ! • `I ). 'r ;y J� 4 { ` "I • '
N, lot 1 EMI -yam' ,4�?•, � �,�gi`�y'i t .1 �-` "' tT 3 J'�\ 0 1t•• I�' '� ii! '+1 R tr '� r
1 f"I + • ' �� � Srr • CI � � - � � � • � � � : � y r • r i � .r, • i :` r �r, J � r
J•d ��a: r� � �y,r, +s 1 • �, 4F, ,. it � r• '� � � � � �
+ 4�+ =' pi° 'i• t� � trr •�y � � � '.i. `� � .1�� 5: °_i •r... i``1 � '\.... % p ti+"r °�' _^(1
+er+ °- �•r.whk �: e � ."•ir1 n fr^, l a• r0 a e;, ^ • 'r 'l ` t �•a .�
jr
_ � mur q �I� , • r`•' w ��i � . r� .7 -, � f� .a r+wc 4��i'rwr�e� f ; tji,�� ���0 a �,pl °�
y_'
'� �, {• �i.17 �$� `• + r►r ,It 1111 � 'Ls .'I''' ,rj o�1.lfF`1r1+.
3j a r.
I 1 _3 � `�' .,,� "' ° � 1 •I 1 , cap .I pry °• y �,+ n*''� , �
6V s
f�l •'I 0 � 1+ .. °y .rnra � 6 4+•Y. 4, •al , +++4rr /� � � \...�
J y r �� "•
kID.
rrr ?
04 \
1 �
`. •+aww �wr+awl.wm...n,+.r.nHrw.ate-..,..�4....•.�..,.°.�...... --- -

ANIMAL WASTE UTILIZATION PLAN
Producer: WILLIAM T. HERRING
Location: P.O. BOX 300
NEWTON GROVE NC 26366
Telephone: [phone]
Type Operation: Existing Feeder to Finish Swine
Number of Animals: 735.00 hogs
(Design capacity)
STORAGE STRUCTURE: Anaerobic Waste Treatment Lagoon
APPLICATION METHOD: Irrigation
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops -
in the fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before. each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply
more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall be applied to land eroding at less than
5 tons per acre per year. Waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on saturated soils, when it is raining,
or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed
under DWQ regulations.
Page: 1

ANIMAL WASTE UTILIZATION PLAN
S. Wind conditions should also be considered to avoid drift and
downwind odor problems.
6. To maximize the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more than 30
days prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. If
you choose to change methods in the future, you need to revise this
plan. Nutrient levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from your
waste management facilicy. In some cases you may want to have plant
analysis made, which could allow additional waste to be applied.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
This waste utilization plan., if carried out, meets the requirements
for compliance with 15A NCAC 214 .0217 adopted by the Environmental
Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
735 hogs x 1.9 tons waste/hogs/year = 1396.5 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
735 hogs x 2.3 lbs PAN/hogs/year = 1690.5 lbs. PAN/year
Applying the above amount of waste is a big job. You should plan
time and have appropriate equipment to apply the waste in a timely
manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
Page: 2

ANIMAL WASTE IITILIZATION PLAN
TABLE 1: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
----
or
------
APPLY
RESID.
APPLIC
METH
N
TIME
11568
2
WaB
BH
5.5
275
0
5.45
1498.75
I
MAR-OCT
11568 1-2
END
SG 11 150 10 15.45 1272.5
I MAY
I
TOTAL11771.25
Indicates that this field is being overseeded (i.e.
inter-olanted) or winter annuals follow summer annuals.
NOTE: The applicator is cautioned that P and K may be over applied
while meeting the N requirements. In the future, regulations
may require farmers in some parts of North Carolina to have a
nutrient management plan that addresses all nutrients. This
plan only addresses nitrogen.
Page: 3

ANIMAL WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
See required specification 2.)
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-- --
or
--------
APPLY
RESID.
APPLIC
METH
N
TIME
END
TOTAL 10
-- indicates that this field is being overseeded (i.e. interplanted) or
winter annuals follow summer annuals.
In interplanted fields (i.e. small grain, etc, interseeded
in bermudagrass), forage must be removed through grazing,
hay and/or silage. Where grazing, plants should be grazed
when they reach a height of six to nine inches. Cattle
should be removed when plants are grazed to a height of four
inches. In fields where small grain, etc, is to be removed
for hay or silage, care should be exercised not to let small
grain to reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too
high and this will definitely interfere with stand of
bermudagrass. This loss of stand will result in reduced
yields and less nitrogen being utilized. Rather than
cutting small grain for hay or silage just before heading as
is the normal situation, you are encouraged to cut the small
grain earlier. You may want to consider harvesting hay or
silage two to three times during the season, depending on
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late
September or early October. Drilling is recommended over
broadcasting. Bermudagrass should be grazed or mowed to a
height of about two inches before drilling for best results.
Page: 4

ANIMAL WASTE UTILIZATION PLAN
** Acreage figures may exceed total acreage in fields due to
overseeding.
* lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and 2 above:
CROP CODE
CROP
UNITS
PER UNIT
BH
SG
HYBRID BERMUDAGRASS-HAY
SMALL GRAIN OVERSEEDED
TONS
AC
BQ
50
TABLE 1
TABLE 2
TOTAL
TOTALS FROM TABLES 1 AND 2
ACRES
LBS AW N USED
5.45
1771.25
0
0
5.45
1771.25
* BALANCE
-80.75
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.
Page: 5

ANIMAL WASTE UTILIZATION PLAN
*** This number must be less than or equal to 0 in order to fully
utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffers, filter strips along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than
the acres shown in the tables_
See attached map showing the fields to be used for the utilization of
animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient
rich and will require precautionary measures to prevent over application
of nutrients or other elements. Your production facility will produce
approximately 271.95 pounds of plant available nitrogen per year in the
sludge.
If you remove the sludge every 5 years, you will have approximately 1359.75
pounds of PAN to utilize. Assuming you apply this PAN to hybrid
bermudagrass hayland at the rate of 300 pounds of nitrogen per acre, you
will need 4.5325 acres of land. If you apply the sludge to corn at
the rate of 125 pounds of nitrogen per acre, you will need 10.878 acres
of land. Please be aware that these are only estimates of the PAN and
land needed. Actual requirements could vary by 251k depending on your
sludge waste analysis, soil types, realistic yields, and application
methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the
soil at the time of irrigation such that runoff or ponding occurs. This
rate is limited by initial soil moisture content, soil structure, soil
texture, water droplet size, and organic solids. The application amount
should not exceed the available water holding capacity of the soil at the
time of irrigation nor should the plant available nitrogen applied exceed
the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables 1 and 2. Failure to apply the recommended rates and
Page: 6

ANIMAL WASTE UTILIZATION PLAN
amounts of nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application
rates and amounts.
I
Tract I Field
I l
11568 2
f
11568 I -2
(Application RatelApplic. Amount
Soil Type Crop (in/hr) (inches)
I �
WaB BH I 0.60 I '*0.96
SG I 1
� I 1
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations, the application amount shown cannot
be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180.00 days of temporary storage and
the temporary storage must be removed on the average of once every
6.00 months. In no instance should the volume of the waste be stored
in your structure be within the 25 year 24 hour storm storage or one
foot of freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply the
correct rates to the acres shown in Tables 1 and 2. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may
make this plan invalid.
Call your technical specialist after you receive the waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate prior to applying the waste.
NARRATIVE OF OPERATION
Page: 7

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
z. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
5. Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
S. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be considered.
Page: 8

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters_
(See Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to
wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over,. -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly into water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
the site.
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 9

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
18. If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site_ .
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22. waste shall be tested within 60 days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when these
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be
maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North
Carolina regulations.
Page; 10

ANIMAL WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm:PORK CHOP HILL FINISHING ##6
OwnerjManager Agreement
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
North Carolina Division of water Quality (NCDWQ) before the new
animals are stocked. I (we) also understand that there must be no
discharge of animal waste from this system to surface waters of the
state from a storm event less severe than the 25-year, 24-hour
storm. The approved plan will be filed on -site at the farm office
and at the office of the local Soil and water Conservation District
and will be available for review by NCDWQ upon request.
Name of Facility Owner: WILLIAM T. HERRING
(Please print)
Signature:
Date:
Name of Manag (If different from owner) :_ TD11 R "%3 etc_
Signature: /5/ v. I DM
Name of Person Preparing Plan: (Please print)Wi.lson Spencer
Affiliation:MRCS Phone No.
Address (Agency): 84 County Complex Rd.
Clinton NC 28328
Signature: Date:
Page: 11

ANIMAL WASTE UTILIZATION FLAN
I,
ANIMAL WASTE UTILIZATION AGREEMENT
(Needed only if additional land has to be Ieased, etc.)
, hereby give
permission to apply animal waste from his Waste Utilization System
on acres of my land for the duration of time shown below.
The fields) on which waste can be applied are shown on the
attached map.
I understand that this waste contains nitrogen, phosphorous,
potassium, and other trace elements and when properly applied
should not harm my land or crops. I also understand that the use
of waste will reduce my need for commercial fertilizer_
Adjacent Landowner:
Waste Producer:
Technical Representative:
SWCD Representative:
Date:
Date.
Date:
Date:
Term of Agreement: ,19 to
(Minimum of Ten Years on Cost Shared Items)
(See Required Specification No. 2.)
Page: 12

ANIMAL WASTE UTILIZATION PLAN
STATE OF NORTH CAROLINA
COUNTY OF
I, , a Notary
Public of said County, do hereby certify that
, personally appeared before me this day and acknowledged the due
execution of the foregoing instrument.
WITNESS my hand and official seal this day of
, 19
My commission expires
( SEAL )
Notary Public.
Page: 13

ANIMAL WASTE UTILIZATION PLAN
I,
Waste Utilization - Third Party Receiver Agreement
hereby agree to apply waste
generated by in a manner that meets the
Waste Utilization Standard (633), or use an alternative waste
utilization system that has been accepted in writing by the
Division of Water Quality.
Third Party Receiver:
Date:
Term of Agreement: to
(Minimum Ten Years on Cost -Shared Items)
STATE OF NORTH CAROLINA
COUNTY OF
I,
Public of said County, do hereby certify that
, a Notary
, personally appeared before me this day and acknowledged the due
execution of the foregoing instrument.
WITNESS my hand and official seal this day of,
19
My commission expires
(SEAL)
Notary Public.
Page: 14

t
1 \yll r
xr ,
t,
F
1 I
4
r { r
A r
r D �4n
�3 J � }f �, n �'J lrfl�'l� �/ �\� !A�° 1� it I 1 �' � •:
r-
'
jq,, 1 f f� r r r" y' r J 1, }i � ij �--' ti y" J i• 1
}, �4':p� .IrZ ti'a .,•� .J }X I'1�� tl' :.r,� r' 4 t 1�
! "f
if
1 �., rpppT�►� 1 '.r1 i "�,.. I I /t�
1 � ♦ t 1
)�-t9-"„ ! rf �c Sl t � f •! )i �7S�J1��• 'i ��i !A � �j?y��S.
k.� q v. " tj' ��t t.'i[ ; . •i 1 I A 1 ! 1 1. ." 1 I5 � � vy�1�1) I � ` ! y v
r {• v� t 1T�..4 r ( 1 r Ijl v �I. RICI 1 � ,� •:
V j•
♦ ter• vR; J�. a , y „ M`31Yryr+-'>1•>'•yR t k J , t�
�... r:.'S �[ ��+yr �•>Y\' :a� a'il�.,:lr. f �1.., Tr i` �.. �`' ._ t\ (.
r�?� "i�h�;t c , k:SJ• �+RJ�� 1l1 1 t rAT •,t;
( n

•
fY / r
:i t�tM1
tt•,
tii
.. r �:� 1 w... f.l3 I,:.. r
f rf r 4 1�•� tr _a
.h

' �f' �� � f"i'�..�;j6ra"-"sIA«k;iai.�•;t`h,•1xr•b::�r6;}l.rw'r;•�'��' ��7F1'•�'''d�.� T•,•." /, d[' �I ,
• ;f.r + r, ,•;�.. �,�'t}•-,..;..t s;..��r'-�f' .tt", d...�,il A;. � �,}',. Wit; "� '.�
' I t • j y.'�." ; ..' ,• 1;. �' l.r„ f i a .i `'!i•': i • 'r. �i.' p • 5' r, �: t t .�f: ' •Y.'yt 4r'�'L4''1"s•,;r.�•ii'r��'rv;•�.,�
+ Y4 � ir��`f I �I �� }, n !�} .�••k - rt- 1ri�1Jr f fr7 •�tt f �I. 5 < -� �, ••� .
I �,1� I 1 1+"r*u4F�''wf[Lfi�+�� ^�f�•��� '11,�,Yy"Ir 'R.4±Y�3��'��1..�}� ���"+71�i 4f J}1 � �F� SAn f. •f1115':.
.A. .,.� �. ..+.�: �_f. tU.•ru>1wE :.a =L..1.Ala.� 7y. �.Yes.l3%.y..:."_s.m'..1:x',L:�ti.. i,�. ..,..... ..��i•-..a.1k _..n. f�._..

.y L=`sxD r"t �.t hh <. '�i:�LnC_'�'.��� y iij:vf:•'k �'.�
i M s . �4 � . 3.'! w1:7.:4::7 .. � st•:'. - t7:;Y: P. ..�a
w'
't
�1CWw .,.w...............
-
- - - - -
- - -- --- -- -- --
y
�
L
i`
-
----
t -
- -
`�-
- -
--
;;Iy
,7 rj
�3
—
-—-
r
L •�'f1
%f�ri
_
cr
1 P
•6_
ool
10
-
--
5r —
— vi `� Yl
R-
IV
-
r1
-
-'T ----...--'--
—'—'Tl"ti
"—� / f
-----•"7%�-�--
1
h
-------------
- -
- - - - -
- -
-
- -
'A&y3 Pawnfd
FOS aFol'3
.1.H
S.9
AG •r213
1O 'S'd
4

'� '��•Yit�iii.���:kf.��'ts '�.+a.t'T �,� . � "' �E. :'sJ? ul�•`�f. .R�, ik a l�•' -F?' A
1 f
-
--
— --
-----
--
i
ias
�r
—
—
—
-
%�
7�
' t+
I
i
— -
—
a1S
Aa13 Pauuold
io 'nala
Ppa aP°a'J
j•k
g g
i
L
i
i

1�- - -- .1 - . . . .
Mortality Management Nlethods
(check which method(s) are being* implemented)
J Burial three feet beneath the surface of the ground within 24 hours after
knowledL-e of the death. The burial must be at least 300 feet from anv flowinz
stream or public body of water,
�s Rendenne at a rendering plant licensed under G.S. 106-168.7
Complete incineration
_1 In the case of dead poultry only. placing in a disposal pit of a size and design
approved by the Department of Agriculture
_! Anv method which in the professional opinion of the State Veterinarian would
make possible the salvage of part of a dead animal's value without endangering
human or animal health. (`Vrinen approval of the State Veterinarian must be
attached)
December 18. 1996

be"Ij
, I'l C a l C.c.s 1 GT;'0-f r
Operator:
PcH 4ib
NonC.otlnty:
'S" a M P 5 0 n
Distanoe
to nearest
residence (other
than owner):
1. AVERAGE LIVE WEIGHT (ALW)
Date: 02/24/g2'
1000.0 feet
O
sows
(farrow to
finish)
Y 1417
lbs. _
0
sows
(farrow to
feeder)
hs. _
310
head
(finishing
only)
v 135
lbs. _
O
C0Ir1S
(farrC44 tq
wean)
Y 433
lhs . -
o
head
( wean to feeder) )
Y Y)
lh.C.,'
Describe other :
Total gverave Live Weight =
2 _ MINIMUM REOI_IIREn TRFATMFNT Vn! I IMF OP7 I Arnnm
ve)I ume = 41850 lhs . AI_E,.1 a Treatment V(7,j,i,lfne( CF )/1-h , a. .W
Treatment Volume( Csr )/ b - Ar_1.1 = 1 /1.h . AI_1.l
Vn_ I1.0 i- = A1650 Cubi f m,=-t
3, .r,,TORAGE vni_!!MF i=QR SLUDGE AC(71_1Mf_'LPTT0N
V-]Bros 1 r fcJt
4 , TnTAI_ ©ES GNED V(IL-UME
0 1bT-
n 1hs
alr�C'0 �hc
n �5 g
n I
0
41 R.�,O j hs
T ns. de too length (feet )------------------------ 120.0
Inside trip width l fe?t )------------- ---- 120.0
Tr,n of dike ejevat ion ( fept )------------------- 4 �J Ye_ e
Bottom of ]?goon ej%:�vat j on ( fe-t )------------ -ia'A
FrA-hr,ard ( feat )-------------------- ------ i n
Sid- Slopes (inside --------------------- i o 1
Total design volomr .,sin:--, nrism, ;,aal fnrmlila
54:�/FNOI SS/FNn2 1,S/G.Tr)FI Sc�/STDF2 f_FNI TH WIDTH f)FPTW
?,l1 n �.f1-� 1 1. 4 n �1a.0 11 C7
ARE3 nP TOP
f FNr_,TH v WIDTH
11.4 .0 114,()
AREA OF 80TTOM
LENGTH -A WIDTH =
4R n 4R.0
1, 2QQH (APFA Or: TnP )
31�4 ( �E?FA OF PnTTOM )
AREA OF MIDS C_'TTnN
I FNrTH WIDTH a
R1 .0 Rj, _[1 2:L,244 (ARF- !1F MTDSECTION * A)
C'I1 FT. faRFA TOP # ( Z*APFC: MIDSECTION) + AREQ RnTTOm-1 nFPTH/A-
I UQk . n 26244.0 2306 .0 i . R
Total Desi?ned Voll_Imp = 76164 CH. FT.

5 _ TEMPORARY STORAGE g,:QUIREO
DRAINAGE APEA=
Lagoon ( top of dike)
Length * Width =
120.0 120.0 14400,0 square feat
Buildings ?roof and lot water)
0.0 sgyere feet Describe this area -
TOTAL DA 14400.0 square feet
OesiQn temporary Ftorage period to hn 190 days.
SA. Volume of waste produced
Feces R, "r i.ne production in gal -May per 135 1 b , ALW 1 , 37
Volume = 41050 lb_, aLW/135 lhs , AUQ * i ?I a.a 1 /doy 180 e=ys
volume = 7.440 nal^ or 10220-1 rvhir_ feet
SE 1JC?l"Me of wash water
This is the amount of frPsh motor "sod for washi pq floors or vol "me
of fresh water i_isnH for ,a flash system Fl"Ph systems: that rar-1rr�,�lat�?
the is oon water are arrni_IntnH for in 5a
Volump = 0.0 real lens/day * 1PO days storgj-/7 do q=i lone
per f F
VclumP = 0 0 Cubic feet
5 , Vr,1_ume of rainfall in excess of evaparation
Use period of tim- when raln011 .eyceeds evaporation by lard-st amount.
180 days exress rainfall _ 7_0 inches
Volume = 7,0 in * DA / 12 inches per font
Volume = 8400.0 cuhir feat

*SD , volume of 25 year -- 24 hour storm
Volume = 7.0 inches / 12 inches es per foot w DA.
Volume = 8400.0 cubic feet
TOTAL REQUIPED TEMPnRAPY STORAGE
5q.
102?0
cubic
feet
W
0
cut i c
feet
5r_, _
8400
cubic
feet
TV
8400
cubic
feet
TOTAL 27020 cubic feet
6. SUMMARY
Temporary stnran? narinr==_=______===_______) !80 rlaw�
Rainfall in oxness of evanorat 7.0 inches
25 year - 7A hour - rainf?ll7.0 inches
1.n feet
Side G2_0 _ i
Inside too length===___________________-____> 120.0 feat
Inside top 120.0 foet
Tap of dike 45,R feet
Bottom of lagnon 11.5 fret
Total required 68170 coy ft. r
Actual denian 7616A cu ft.
Seasonal high watertahle ei ev t ion (SHWT 1===> 4L0 ><,n feet
Stop pumoin; Flee '+ =41%2 feet 7k
Must he ) or = to the Sf-IWT clot/ _ _-__-_-) 11.0 54,n feet
Must be ) or = to min. req. `re?tment el .-) WR feet_
Required minimum treatment 41550 cu- ft.
volume at stop pumping elevation====-=======? 46787 cu. ft .
.tart PQMpinn A1?1�. ___-____-_----_-_-_-___-) 44.2 feat
MuFt be at bottom of freebn?rd X 25 yr . rainfall
Actual volume less 25 yr - - 24 hr rA 0f a l l ==) 6776A cu, ft
Volump at start pumping ple"ption===========) 62610 cu ft .
Required volume to he 1F620 cu. ft �
Actual volume planned to be 21R23 cu. ft . �
Min. thickness of yoil l inpr when rpgy red=-) 1„R foot
7 DESIGNED eV � 40PROVED PY- (�
MATS : o�/ Z `7� �AT�
57
NOTE: SEE ATTACHED WPSTE UTI T _AT ION PLAN
COMMENTS:

Qperator:PCH 06 Existing County: 90-pson
Date: 02/26/P7
Distance to nearest ; esidenre (ether than owner):
1000_0 feet
1. AVERAGE LIVE WEIGHT (ALW)
0 sows (farrow to finish) Y 1417 lbs.
- n lbs
0 sows ( farrow to feeder) v 522 lbs
- n lbs
425 head (finishing only) v 135 lbs.
- 57375 lbs
0 sows { farrow to wean) v 4-33 lbs.
- 0 lbs
0 head f wean to feeder-30 lbs.
- 0 lbs
Describe other
Tnt.aT Aversoe Live Weight _ 57?75 lbs
2. MINIMUM RE4UTREn TREATMENT VOMME OF i_Arnr)N
Volume = 57375 lbs, Ai M Y Trext{Tpnt VVlVMp(
Cr )/j h . AI w
Treatment Voluma(CF)/lb. ALL
volume = $7075 cubic feet
9. STnPQGE VOLUME FOR SLUDGE DGE A(`CUMI.II_ A T I ON
Volume = cubic feet
4. TOTAL DESIGNED Vnr r NE
Tnsi rye ton length (feet) ---------------------
M-0
inside tort width (feet) ----------------------
W.0
Too of dike elpwat i nn (fpet )----------
Botrom of laannn elevation (foot) ------------
yd ,q
Freeboard 'feet) ----------- L -----------------
1 .n
Side slopes (inside lagoon) ------------------
2.0
Total desinn ValuTe using nrismoir-s! formula
5S/ENDI %S/FN02 SS/STDE cS/STDF2 LENGTH
WIDTH [DEPTH
2.0 2,0 2 L() 2-0 1.16.0
1.11 .0 Q.a
APED nF TOP
LENGTH * WIDTH =
116.0 ill .0
12076 (AREA nr TnP )
AREA OF
RnTTOM
LENGTH
* WTOTH =
704 d
71. , 4
5475 ( AREA
OF BOTTOM)
AREA OF
MTOSECTTnN
LENGTH TH
WIDTH *: 4
96.2
91 .2
0=004 (APEA
OF MIDSECTION * d )
C1.1 FT.
= [AREA Top t
(6*AREA MTDRFQT jnM)
+ AREA eOTTnM_1 DEDTH/6
12876.0
?TOO? ? �
5455.0 1 .6
Total Dosinned volume
Avoilable = 88151 r" FT.

5_ TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon ( top of dike)
1 enwth * Width =
120 _0 t 15 _n 11900.0 square feet
Rini ldi ngF ( roof and lot water)
it ,0 square feet pescr jha this area-
TOTOL nA 11800.0 square feet
Design temporary stora?e period to 180 days -
SA. Volume of waste Produced
Feces & urine prnduCt i on in To! . /flay per 115 1b . Al W 1 9-7
Volume = 57.275 l.Ms . A4r,►/1?5 lhs PLO * 1.17 o? l /day I ery rays
volume = 104805 gals, or 1an11 ,a cubic feet v
08 Volume of wash water
This is the amount of fresh water used for wvshinv floors or valyme
of fresh water used for a flesh system. Flush systems that racirr�il?to
the Wnon water area acenunt-H for in 5A ,
V0111ma = 0.0 gallons/day 180 riayF storag-/7 AR ryA!IonC
pear Cr
VOW. = 0_0 cubic feet
50. Volume of rai nfP1 l in e-ress of evaporation
Use period of time when rainfall ?--Pori- evaporation by l?rVost amni_int
180 days eyoo s rainfall _ 7.0 i mhos
Vol"me = 7 _0 in * D4 / 12 i Pohss per foot_
Volume = $050.0 cubic feet

aD . Volume of 25 year - 24 hour storm
Volume = 7 _n inches / 12 inches per foot * DA
volume = 80.50.0 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
4. 14011 cubic feat
5? . 0 cubic feet
Sr , 8050 cubic feet
tirl _ 0050 cl rl_. i c feet
TOTAL. 30111 cubic feet
6 SUMMARY
Temporary storage
180
days
Rainfall in excess of atlai7t r?tinn===s--==-_-}
7.0
inches
25 year - _'4 hour
7 ,O
i nchns
1 0
feet
Inside too 1anntF;=�_________________________}
1?n_n
foot
Tnsidn tor,
n
feet
Top of dike
45 0
fe-t
Bottom of isTo n
9
fWnt
Total required �r��l,_rmq-==____________________)
874P6
c,_r
ft :*
Actual desion
R9141
V1 .
ft.
Seasonal high watertabio elevation l5HWT1===)
?5.0
fast
Stop pumping
4? 2
fe-t
�.
Mist be ) or _ to the $HWT e l-=+.� . - __-_-_-_?
TP _0
fart
Must by ) or = to min. re?, trWatment ej .=.
40.9
foot
Required minimum treatment
57375
c".
ft
Volf_Iil1P_ at stop 1]!r{'p n17
57k4P
ou-
ft.
Start. pumping
44.2
foot
:x
Must by at bottom of freeboarS X 25 yr. . rainfall
Actual, volumo less 25 yr,- 24 hr, rainfall==}
Polni
cu
ft.
VnIume at Start pumping
805e7
cu
ft-
Required volume to by pr_rrtl[a,arl=====_=_=_______>
-22061
rr_r _
ft �
Actual vols_Imp planner{ to be
22q?9
cu
ft. �.
Min. thickness of Gail liner when required==1
1 6
feet
7 . DESIGNED By: owo?� aOPTOVED BY:
17
Of%2Y75 7
DATE, DATE
NOTE: SEA: ATTACHFD WASTE UTTi_IZP71 N PLAN
COMMENTS:

0FERA110N & MAIN-F NANCE PLAN
Proper lagoon liquid management should be a year-round priority. It is especially
important to manage levels so that you do not have problems durin€: extended rainy and
wet periods.
Maximum storage capacity should be available in the lagoon for periods when the
receiving crop is dormant (such as winterti—me for bermudagrass) or when there are
extended rainy spells such as the thunderstorm season in the summertime. This means
that at the first signs of plant growth in the later winter/early sprung, irrigation according to
a farm waste management plan should be done whenever the land is dry enough to
receive lagoon liquid_ This will make storage space available in the lagoon for future wet
periods. In the late summer/early fall the 'agcon should be purnpec down to the low
marker (see Figure 2-1) to allow for winter storage. Every effort should be made to
maintain the lagoon close to the minimum liquid level as long as thi: weather and waste
utilization plan will allow it.
Waiting until the Iagoon has reached its maximum storage capacity )efore starting to
irrigate does not leave room for storing excess wat; r during extended wet periods.
Overflow from the lagoon for any reason except a 25-year, 24-hour storm is a violation of
state law and subject to penalty action.
The routine maintenance of a lagoon involves the following:
Maintenance of a vegetative cover for t-ie darn.
Fescue or common bermudagrass zre the most comm:)n vegetative
covers. The vegetation should be fertilized each yea,, if needed, to
maintain a vigorous stand_ The arnount of fertilizer i pplied should be
based on a soils test, but in the event :hat it is not pn etical to obtain
a soils test each year, the lagoon embwnkment and su.Tounding areas
should be fertilized with W-� pounds per- acre of 1Q-1 ]-10, or
equivalent.
Brush and trees on the embarkment rr.u3t be controll� d. This may be
done by mowing, spraying, =-,zing, chopping, or a t ornbitnation of
these practices. This shoule x done at least once a) ear and
possibly twice in years that we -titer conditions are favorable for
heavy vegetative growth.
NOTE: If vegetation is controlled by sera, i.t:c, the herbicide must not be allowed to enter
the lagoon water. Such chemicals could ha 7mthe bacteria in the lag oon that are treating
the waste.
Maintenance inspections of the entire lagc-or. shou'.d be made during the initial filling of
the lagoon and at least monthly and after r: zjor rainf�-l± and storm el,ents. Items to be
checked should include, as a minimum, tt::. milowir.g:
Waste Inlet Pies, Rccycling PiDe5, and Overflow Pipes ---look for:
1. separation of joints
2. cracks or breaks
3. accumulation of salts o- riirye:G's
4. overall condition of pi:—ts
Zd WtrLv : 80 000z 18 .,%ON 'phi XUZJ

Lagoon surface ---look for:
1. undesirable vegetative growth
2. floating or lodged debris
Embankment ---look for:
1. settlement, cracking, or "jug" holes
2. side slope stability --slumps or bulges
3_ wet or damp areas on the back slope
4. erosion due to lack of vegetation or as a result of wave action
5. rodent damage
Larger lagoons may be subject to liner damage due to wave action mused by strong
winds. These waves can erode the lagoon sidewalls, thereby weaker ing the lagoon dam.
A good stand of vegetation will reduce the potential ea.mage caused by wave action. If
wave action causes serious damage to a lagoon sidewall, baffles in tf a lagoon may be
used to reduce the wave impacts.
Any of these features could lead to erosion and weakening of the dari. if your lagoon has
any of these features, you should call an appropriate expert familiar with design and
construction of waste lagoons. You may need to provide a temporar f fix if there is a threat
of a waste discharge. However, a permanent solution should be reviewed by the
technical expert. Any digging into a lagoon darn with heavy equipment is a serious
undertaking with potentially serious consNuences and. should not be :onducted unless
recommended by an appropriate technical expert.
Transfer Pumps ---check for proper operation of:
1. recycling pumps
2. irrigation pumps
Check for leaks, loose fittings, and overall purnp ox=a:ion. An unu many loud or grinding
noise, or a large amount of vibration, may ne:cate th-rt the pump is in need or repair or
replacement.
NOTE: Pumping systems should be inspe-=d and operated frequent.y enough so that you
are not completely "surprised" by equipment failure. You should pe.-form your pumping
system maintenance at a time when your lagccr. is at -. s low level. 1 his will allow some
safety time should major repairs be required. Having a nearly full lagoon is not the time
to think about switching, repairing , or bo.-rowing pumps. Probably: if your lagoon is full,
your neighbor's lagoon is full also. You should consider maintaining; an inventory of spare
Pam or pumps.
Surface water diversion feats:. -es are designed to carry all surface
drainage waters (such as rainfall runoff, roof drainage gutter outlets,
and parking lot runoff) away from your lagoon and odder waste
treatment or storage structures. The only water that sl.ould be
coming from your lagoon is that which comes from your flushing
(washing) system pipes and t e rainfall that hits the lagoon directly.
You should inspect your diversion system for the following:
1. adequate vegetation
2. diversion capa-ity
3. ridge berm height
�rl LIHtv,RM DIMMP T? 'nON 2ETEgf; ;7—F; : 'ON Xd-A : WMW

Identified problems should be corrected promptly. It is advisable to inspect your system
during or immediately following a heavy rain. If technical assistano: is needed to
determine proper solutions, consult with appropriate experts_
You should record the level of the lagoon just prior to when rain is Predicted, and then
record the level again 4 to 6 hours after the rain (assumes there is no pumping). This will
give you an idea of how much your lagoon level will rise with, a certain rainfall amount
(you must also be recording your rainfall for this to work). Knowing, this should help in
planning irrigation applications and storage. If your lagoon rises excessively, you may
have an inflow problem from a surface water diversion or there may be seepage into the
lagoon from the surrounding land.
Lagoon Operation
Startup:
I. Immediately after construction establish a complete sod cover on bare soil
surfaces to avoid erosion.
2. Fill new lagoon design treaLment volume at least half full of water before
waste loading begins, taldng ca:-e not to erode lining or bank slopes.
3. Drainpipes into the lagoon shz u d have a flexible pipe extender on the
end of the pipe to discharge tear the bortom of the lagoon during'initial
filling or another means of sjowing the incoming Ovate' to avoid erosion of
the lining.
4. Wnen possible, begin loading new lagoons in the spring to maximize
bacterial establishment (due to warmer weather).
5. It is recommended that a new :a4 oon be seeded with si udge from a healthy
working swine lagoon in the a:7;cun-. of C.25 percent of the full lagoon
liquid volume. This seeding. s o tld occcur at least tw) weeks prior to the
addition of wastewater.
6. Maintain a periodic check on t c lad ocr liquid pH. if the pH falls below
7.0, add agricultural lime at the ra.e o 1 pound per 1000 cubic feet of
lagoon liquid volume until the pH rises above 7.0. (l,dmum lagoon liquid
PH is between 7.5 and 8.0.
7. A dark color, lack of bubbling. and excessive odor signals inadequate
biological activity. Consultaticr, wi:) a technical specialist is recommended
if these conditions occur for prolonged periods, especially during the warm
season.
Loading:
The more frequently and regularly that wastcwater is added to a lago m, the better the
lagoon will function. Flush systems that wasr, waste into the lagoon ;everal times daily are
optimum for treatment. Pit recharge systerns, in which one or more )uildings are drained
and recharged each day, also work welt.
cd wt ":e0 000z iz 'r�ON : 'QN xa-A : 1408.�

Management:
Practice water conservation• ---minimize building water usage and
spiHage from Ieaiang waterers, broken pipes and wart down through
Proper maintenance and water conservation.
Minimize feed wastage and spillage by keeping feeders adjusted. This
wilt reduce the amount of solids entering the lagoon
Maintain lagoon liquid level betwe~n the permanent storage level and
the full temporary storage level.
Place visible markers or stakes on die lagoon bank to ihow the
minimum liquid level and the maximum liquid lever (Figure 2-1).
Start irrigating at the earliest possible date in the spring based on
nutrient requirements and soil mois:are sea that temporary storage
will be maximized for the sum;ner thunderstorm seascn. Similarly,
irrigate in the late summer/early fall tc provide maximum lagoon
storage for the winter.
The lagoon liquid level shou& never b:. closer than 1 'vent to the lowest
point of the dam or emba kmant.
Do not pump the lagoon liquid level leaser that the peznanent storage
level unless you are removing sludge.
Locate float pump intakes arpraxirna=._ "• 18 inches ur.3emeath the liquid
surface and as far away from the drrsn. pe inlets as passible.
Prevent additions of bedding ma_e:-ials, long-stemmed forage or vegetation,
molded feed, plastic syringes, or other foreign materi0s into the lagoon.
Frequently remove solids from catch basins at end of ,onfinement houses or
wherever they are installed.
Maintain strict vegetation, rccer}t, and varmint contro. near la©oon edges
Do not allow trees or large bushes to 2--ow on lagoon dam or embankment_
Removc sludge from the lagoon either when the sludg! storage capacity is
full or before it fills 50 perce;.t of t,,e permanent storage volume.
If animal production is to be terminatel, the owner is responsible for
obtaining and. implementing a closure plan to eliminat+: the possibility of a
pollutant discharge.
Sludge Removal:
Rate of lagoon sludge buildup can be reduced by:
Sd WbS17:8O 000?- TZ *^ON Mc. 6?:@t5 : 'ON Xdd : WOdJ

proper lagoon sizing,
mechanical solids separation cf flushed waste-,
gravity settling of flushed waste solids in an appropriaiely designed basin, or
minimizing feed wastage and spillage.
Lagoon sludge that is removed annually rat2her than stored long term will:
have more nutrients,
have more odor, and
require more Iand to properly use the nutrients.
Removal techniques:
Hire a custom applicator.
Mix the sludge and lagoon lirtu_c with a chopper -agitator impeller
pump through large -bore sprinkler irrigation system otito nearby, cropland;
and soil incorporate.
Dewater the upper part of lagoon by irrigation onto nearby cropland or
forageIand; mix remaining sludge; pump into liquid sl Age applicator; haul
and spread onto cropland or fcrage?anL; and soil ineoporate.
Dewater the upper part of lagoon by i--igation onto nearby cropland or
forageland; dredge sludge f-oim lagoon: with dragline cr sludge barge; berm
an area beside lagoon to receive the sl,-dac so that liquids can drain back
into lagoon; allow sludge to dewatc ; : aul and spread x1th manure spreader
onto cropland or forageland; wid soil incorporate.
Regardless of the method, you must have the sludge. rraterial analyzel for waste
constituents just as you would your lagoon wzter. The sludge will ct ntain different
nutrient and metal values from the liquid. %e anulication of the sludge to fields will be
limited by these nutrients as well as any pre : iJ'�s way;e applications to that field and crop
requirement. Waste application rates will be discussed in detail in Chapter 3.
When removing sludge, you must also pay attectien the liner to pr-.vent damage. Close
attention by the pumper or drag -line operator will ensure that the lagoon liner remains
intact. If you see soil material or the synth: t:, lints Material being d sturbed, you should
stop the activity immediately and not resume until you are sure that tee sludge can be
removed without liner injury. If the liner is dana-jeci it must be repaired as soon as
possible.
Sludge removed from the lagoon has a muc higher phosphorus and Heavy metal content
than liquid. Because of this it should probably be ape ii;�d to land with low phosphorus
and metal levels, as indicated by a soil test, and irco�orated to reduce the chance of
erosion. Note that if the sludge is applied to fields w::h very high so 1-test phosphorus, it
should be applied only at rates equal to the crop removal of phosphorus. As with other
wastes, always have your lagoon sludge anL-vzed for its nutrient value.
The application of sludge will increase the;:ncunt of odor at the waste application site.
Extra precaution should be used to observe the wind erection and other conditions which
could increase the concern of neighbors.
3d WbSV:e0 00tZ 12 '^QN : '014 Add : Wo�u

Possible Causes of Lagoon Failure
Lagoon failures result in the unplanned discharge of wastewater froln the strvctuirc. Types
of failures include leakage through the bot=om or sides, overtopping, and breach of the
dam. Assuming proper design and construction, the owner has the :rsponsibility for
ensuring structure safety. Items which ma., lead to 13000n, failures include:
Modification of the lagoon sc:ructure---an example is -he placement of a pipe
in the dam without proper design and construction. (Consult an expert in
lagoon, design before placing any pipes in dams.)
Lagoon liquid levels --high levels are a safety risk.
Failure to inspect and maintain the dan,
Excess surface water flowing into the lagoon.
Liner integrity ---protect from inlet pi-,-- scouring, daria„e during sludge
removal, or rupture from louerrg laz on liquid level below groundwater
table.
NOTE: If lagoon water is allowed to ovenop ;he da-n, the moving water will soon cause
gullies to form in the dam. Once this damage sans, it can quickly ,muse a large discharge
Of wastewater and possible dam failure.
Ld Wb,9v:80 000Z TZ 'noN ZZIc= =]T6 : '034 XUJ : Woi:u

EMERGENCY ACTION PLAN
PHONE NUMBERS
DIVISION OF WATER QU" ITY (DWQ) _ 910-24-15.411
EMERGENCY h1r,NACEi'ANIET SERVICES (=�.1S)-
SOIL AND WATER CONS7RVATION DISTRICT CT (SWCD) 910 -5,9 A _ 79 f"?
NATURAL RESOURCES CONSEs�V",TIO SE7VICE (iNRCS) 9rn—s`�,�—�i�3
COOPERATIVE EX T ERSION SERVICE (CES) 0110-Ea -7 4t
This plan will be implemer zed in the ever,- t^a. wastes from your operation are leaking,
overflowing or runnina cff siie. You should not wait until wastes reach surface wavers
or leave you property to consider that you l"2ve a problem. You should make every
effort to ensure that this does not happen. This plan should be posted in an accessible
location for all employees ai the facility. The following are some action items you should
take.
1 . Stop the release of vras►es. Depending on the situation, this may ore may not be
possible. SugC?SieC responses to some possible problems are listed belwo.
A. Lacoon ove-ficw-possible solo;ions are:
a. Add soil c, verm to increase e.eva.ion Of dcm.
b. Pump was.es to fields a, an acceptable rate.
C. Stop all flows to the lacoon i,:.mediately.
d. RCall a pum':Jna contractor.
e. {Y1GI{p rJtirC 7.0 S6;riace IVVa._. is M Ler:ng IF -coon.
E. Runoff from, via5ie application,,-Neid--Ctions include:
SLoD wa5t?
b. Create a :_ :,porary diversic'- :o Cor,'ai,h Waste.
c. Incorpora:R Nast- to r{rruc=
d. Evaluate and eliminate the -easen(s) That cause the runoff.
e. E laiva a appiicat.ori rails -: r ir-,e fields Where runoff occurred.
C. Lea{'c`e from; _-e waste pipes ant sprinklers-actlon include:
E. Stop recYc:e pump.
b. Stop in"r-E,:on pump.
c. Close vaives to eliminate further discharge.
d. Repair ail iea{s prior to re-s-ar.inc pumps.
D. Leakace sr,....'kush sysie.—.s, ho'usas, Solid separGlors'ac:ion include:
a. SiUp recycle pump.
b. :fop imc-:son pump.
c. Make s--e s:c„on occurs.
d.. Sicc all fi`v.,s in the house, sys-,ems, or solid separators.
E. i e-akEge frc.' _ ase or sidewa'! 0" ';a+00n. Often this is saepace as Opposed
-;� .o:•� c '�_ts-sass:bie actiL-.
a. s ;,-i'J eiimbankment to catch all
se_1ac'e a s,.,tmers,bie . _- . ar,d pump back to'2goon.
V :'tiles a :--us=C Dy rii-"7 :`:., y animals, trap or rer oVe animnals and fiil
ho vs and. cL . =act ,.vith a clay _y" e scii.
c. rage c conditior, of the side Wails and laaaoon
bo cs :c- as pcssibi=

2. Assess The exteni of the spill and note any obvious damages.
a. Did the wzste reach any surface
b. Approximately how much was released and for what duration?
c. Any damage notes, such as employee injury, fish kills, or property dam -ace?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
c. Are potable water wells in danger (ei.her on or of; the property)?
h. Now much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours call your DWQ regional office; Phone - -. Ater
hours, emergency number: 919-733 =2. Your phone call should include: your
narne, facility number, telephone nunber, the details of the incident from item 2
above, the exact location of the fscili.y,..l ,,e location or direction of movement of
zhe spi'il, wcainer and wind conditiC-:a. T.-le- correC,ive rneasur:5 ha-L have been
under taken, and the seriousness of ,he si iutlon.
b. if spill leaves property or enters surface Wafers, call local EMS phone number.
c. lns'ruc: EMS to contact local heiGt,n Deoarfrnenz.
d. Contact CES, phone number - , local C'vVCD office phone numiber - -, and local
NRCS office for advice/technicai assis._-ce phone number - .
4. if none of ,�,e above 1fvorks call 9 1 1 or f'.. Sheriff's DepGrmen- and explain you
problem :o hen and. ask t+he person -o ccnzact the proper agencies for you.
5. Con-LaC, the contrcc-or of your choice .o begin repair or problem to mini-mize oi 1-
Site dar -ace.
a. Contractors Namne: L4- T Cpn5, CS. 0.1^K 4k'r
b. Con-Lractors Add7-25S. :U
c. Contractors Phone: 94 -,3?o(,
6. Co zaC: i`,c technical specia+iS: Nvhc G ".' eG L Ie lagoon (NRCS, Consulting
Enc ineer, e:w.)
a. Name: SiJen- eJ"
b. Phone:-
7. 1m 1ern-,.. procr_ S as edvi-,zed t'f ✓}.�. a. iC
raC_ity t _. w.5M.2Cv, �v'aIr _:1e sys- .macr a-ssess tr`,e F-s rnE 7 af-M plc7, l0
<eeP Prot- m.s w:4, Ccsa o, was es c happening again.
2

sour:e
SWINE FARM WASTE MANAINGEN ;ENT ODOR CONTROL CHECKLIST
Ca::se
.. F'S :z Minimize Odor
i=arrnsts 3� Swint arccuc:ion 've;eNave or wooced 'Duffers;
{._,,;�t==mmenced pest management
pra:_Ces:
lrr�L3c ':_d ymen* and cormon sense
Animal body su:�aces Diry nanure- overed animals
F:o:. sL^acts die. ^,2RL.. __-Ve'_., floors (f floors;
Ae''h'aterers located over siore_ floors,
( )=e-eders a: 4icn er%d of sciid floors;
( 1 Sc-ape manure buildup from floors;
( ) ::.^w:e-7bor ventilation for drying.
Manure coliecJon Pits Brine i=-et;::ert manure renovai byflush.pit
rec".ar„e,or scrape
°2n;zl :iccr_iai a._omposi;jon (i :i~d±Moor ven:iia;ion
Vtzziie:ic') ^_xhacs: `ens Voia:iie ;ases: ( ; -_n eintsnance,
pus: ( ) _..: air movement
incccr sL:races lvr, asr-,=own ae:ween ercups of animals
. ( =tec,.awns=cL.-. ex:nnds•s to
ea_e- C_v!rs
Size Specific Prate ices
;a^•-5 ;itaticn c-._:y�iea lagoon (
liquid wniies :ar.Ks art Riling ( ) __:e-d ael lines :o near .ct:= o`
__:.43 Wit^ a^:i-si."sCR vents
r.�SR a?iCvs :.;;ta-jcn .LriA; wastewater i. I w mod' -:CC: 'IL'sn w1:79 un�_tn!=cr
-it recnar;_ points ,:;i:a rcr, cf tcyc!ed lagoon ; , =ors-e:narc lines .o nesthc;:cn w.
;ic.uid w-iie :its are fiiGng =i-s .-i:n anti-sir^on vents
L"- s a.._ns :.;i:a ibr. __..r.; sL-p tank filine ( _ ^K cbve:s
and drawdown
CiV!5i„'�.E :-air. coilecticn A.;itation C�riR; Was;ew8ier { ) Sox ;;:,vets
or junction, :cx!s conveyance
=.,d of drairtzipes a: !C.-ten A;station cunag wastewater { 1 Este-==iscrEr;c Point of pipes
uyee:-eath la;ocn licuid level
La -.Con st:'ects Vcla:iie ;as _—^ ss any - . _ _ i2ya,n li�Zuiz LapaCa'/
Eicic;ical II^G ( W r!:. !a;oD^ star: . �r7eeCJr7s
ar-2-to-Volvme ratio
a;i:a:icn when pur^:i;y
aeration
ir'i;=_.ien Sw ^i1!r ^cC_.es Tier ass_.- e,:;a:ien --=a _ cR _.ri _ays wit.. ii�!e or !;o .viral
..._ ,,:a'. ;✓'_..... _.....c..-r:-:ea_-.. creration„ tss:.._
!✓C��; n:a[e near ia; cn Ii �L'i.'. vx act
.....•.. a ct:.. ce: i i_�_

ra,;c :enk or resin Panial rvi:r.nial decornpcsition { } =7:v-. or midlevel loading
sur`ace Mixin; W;^iie fiiiing ( ) i ank a=vets
.'. yi,26cf^ , -'Ien erntying ( ) Za5iC1 b"'rfaCn mail cf SOli-�s
O ?•owe• 5iological ado;Tives or csi:enis
se —;in; ccsin s_rfa_e Panial miCC iai decomposition ( J =r_ene drainpipe ou-lets vndernea:;i lieuie
Mixin.- who -se filling levei
Agitation when emptying () Remove settled solids regularly
ftert:re, Si_r-J or siudae A;i;ation, ++'sera s;reading {) S; it injection, of slurryisiL_¢es
spreacer outle-s Volatile ;as :-vssions { ? Wasn residual manure from spreader efter use
(} P:-oven biological additives or oxidants
Jnccvered manure, slvey Voia ile ;as errrssions wnil!e drying {) Soil infection of slurryislud,es
or s:Ldys on ficid surfaces { i Sail incorporation within 4a hours
(} Spread in thin uniform layers for raid drr ng
(} F:�cvem biological additives or oxR_ams
Dead anirneis Carcass UGC--mpcsition {if'?: «er disposition of carcasses
Dead ani-ai=isz!Cszi :af:asS :e LJr^.ric5i ticn (1 :,lea covering of zarzasses in
pits { ?-Deer location/construction o.r diszrsal ;its
lneir.e =:crs lncorn ie:. ustion ( } SGecr+dery stark burners
St3-din; we-er ar_,:nc !r, cper _raica;a 7G. =be and landscape such that wat: =rains
fac:;i;.es �Sicro:;al de:_nccsiticn of a w av =rn `.aciiities
r;a:ac -,an_.
•ur_ ".ac _c _..._ pc.._ -_cr'; r,a1^.'_ire. access roads (=zr... ac=ess road maintenance _
__cs fr_... ` aC..ess
Additicnai lr.:cr-a;ion.
Swine G _ZDG =c;: Packet
Swine-...C_::icn Far- :e^;ial v-Cor w _,_Gs and 'Remedies, c-r.E Far. S:,e►t
S'-vi . !CG:rG;.cn Faciii-( `ri aflt.,rs 1lena r e...en:. Fri nachar ;e -L 3y^GU'r1 1 .ea -Mar-% E-Zn--- I22-S2
S wine=-oducaorn Faciii:y 1.1anure Wana;vnent: Underfloor Fps se --may cc--rea:.-ner.;i c= = i
La;oon Gsi; and and Stcrc-;e;
Caiinra;:ar, Of tier, re ar_ :'lest -war.. AL;iication=quipment, E—BAH. =a=_ Sneer
�y nt'_gi�a Cry ,s fmr:'1 Swine F.."-.334
-nvlrzr.rtntal AsSiJranc P.-t:gram.: NP:C Manual
C—Ptions rp ..:a^a ;ir.� Dec , a reper: fivr the Swine Odor i ask F=rze
Nuisancz ,.cr,ce:rs in ..-;-al annure'..ara;trnenT: Ocors and Fiies; Ci, iSSS Conferent_ ?res-_:ins
„vaiiai);e From—
T30=is-CaUny ;Y.ensit.ri Cente
BA
h'CS iS-SAc
NCSU-Swine x--erasion
.NC Pork Produces Assoc
4CSi-i A.-.i Com^7L'nioa«cr
F:crida Coeperative x-ension
The Ts ii`"is O.Defaiioil. The aCr=Q_ i'.. USE szvu..j iU%Cgi.1ar7: in applying
GGGr �,Cl ; icaSDreS iE5 PrEC-J--al.
pC_r r3iiol YcS: 1CVe ba?rl C+ T12_
To

INSECT CONTROL CHE-CKLIST FOR ANIMAL OPERATIONS
5e �� C?use ...7r s .. f.1in:r.ize 003r Site Specific Flrac ices
r'rLsn Gu-,,Crs
rcaurnulation of solids
;./_ _sr. Sps:ern is designed anc
su'rccientiy to remove accumulated
seilas frorn putters as desi;rled.
{) RenCve brie„irns of ac:amula::: soiics z;
dis--barge
Lagoons and Pits
cr",ed sa{ids
vlair:gin lasoons• sonlir.p basins and
pi-s wriare ;rest breading, is apoaren; :a
-
rnir^tir-;i_e :}tie crain-y of soli;. ;D a dt;;-h
of no more than 6-8 inches over mare than
ZC% of surface,
zcessive ve;e;ative
Deca,.nnp vegeradon
?.'ear.;gin ve;,e:ative control aior.; darks o.
G.=W:h
Ia;Dons and D..her irnDcuZdner.a
2=�C^..L'igllCr Df decayin; ve;e,2t1ve
boric, 'heater's ed^ye Dr. imDoL:nc'ne .t's .. fimetzr.
reacers
;eat spilla;,e
and raaintair. f._: Sys -erns
_r.d ..__;rs', .. n-ini-._ :ne
s::iila;e or, a rcL':111e nsls (e.;. 7•10 day
-�urir; summer: i-,a.; L,_r+zi „_rim;, winter).
Fee_ 3;_ra-„e
nt:_.mulaucns c. feed residues
ar^Cnd
irnr-.e_iote;erirneter Df geed srr•x;e are=s cy
ins--^na draina;e away from site ar.G:cr ;rDL'1di^fy'
•. c_t:e , cr::airment {e., -� -- din c,
= s —e 's ;ruin and similar hi;- rnois:_re = ain
Anirnai ^ oiling ,:,lees l ocurnuletions of animal wastes
and feed was;r;e
f ] •r:s_e _.:cr and ra,move a- break .c ac_.-_iated
5 iiGs :r :ilte, $: ;s a^Dino tee_ s:_ e;e as needed.
{) Eii:^ina:t low area ;ha-. :rap nzis:_re Lien; fonds
and Cr locations w:^,ere Waste ac=,mvia:ts and
a-C �i5:�r�a nCe by anir-ais is rninir•ai.
(} F.•zir. fir. !trice rows arz fll;er s:r::s aro_nc a.i-al
arse: ;D minimin accurn---la-.icns --f wastes
ti a. ,eCcvt = _tc c xcc_-tie:eyr
¢D.iDs es

,,,,,y ,Manc:re Handling Accumula[iona of animal wastes {) nennove spillage an a routine basis W-..7-10 day
Systems ir.:ervai during summer; 1 S-30 days imenral during
winter) where manure is loaded for land aoplicetion
or disposal.
t ) Provide for adequate drainage arour4 manure stockpiles.
{ ) Inspect for and remove or break up accumulated wester
in /ilrcr stripes around stockpiles and manure handling
areas as needed.
The issues checked ( ) pertain to this operation. The landownerAntegrator agrees to use sound judgment in applying
insect control measures as practical.
I cer:iry the aforementioned insect control Best Mana;ement Practices have been reviewed with me.
(_ando•.vner Signatur!-)
i=or more it fcr,:,a icn contact :he Caoperative Ex-ension Service, Dec8 L c. Entomology, pcx 7a i3, Vic- .tc=]ir.a S:a:e `Jnive:s::y, Rale;s,h, N:
'!739=-7 = ', 3,
AIMIC—tioverber 11, 1Sas

State of North Carolina
Department of Environment and Natural Resources
Division of Water Quality
Non -Discharge Permit Application Foi
(THIS FORM NiAY BE PHOTOCOPIED FOR USE AS AN r INAL)
General Permit - Existing Animal Waste Qerations
The following questions have been
review the information for come
question has not been cornplet l
1. GENERU INFORM.
Facility Dame: Pork Chop Hill T
1.2 Print Land Owner's name: Willi:
1.3 Mailing address: PO Box ,00
City, State: Newton Grove NC
Telephone Number (include area
eteness and make
the Division, plea
AT
any-ques i kpai
i Fle Mhe Division. Please
hat are appropriate. If a
best as possible. Do not leave
R5CEI'
..n r cr[ uuAUTY SEC7i0N
Zip: ?8366 � V _
1.4 County where facility is located: Samysl6h _ /f
!1
1.3 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a copy
of a county road map with the location of the f jj�n identified): Farm location: 1 mile west of Rt. 701 off SR_ 1800
1.6 Print Farm Manager's name (if different fr t�tand Owner): TDNI Farms Inc.
1.7 Lessee's / Integrator's name (if applicable; please circle which type is listed): Newton Grove Grain and Feed
1.8 Date Facility Originally Began Operation: 1111197s
1,9 Date(s) of Facility Expansion(s) (if applicable):
2. OPERATION INFORMATION
3.1 Facility No.: 82_ (county number); 488 (facility number).
2.2 Operation Description: Swine operation
Feeder to Finish
735- Certified Design Capacity
Is the above information correct'? 71yes: ano. If no. correct below using the design Capacity of the facility_
The "No. of Animals" should be the maximum number for which the waste management structures were designed.
Tvpe of Swine No. of Animals Tvpe of Poultry No. of Animals Tvpe of Cattle No. of Animals
0 Wean to Feeder v Laver 0 Dairy
0 Feeder to Finish 0 Non -Layer 0 Beef
0 Farrow to Wean (T sow) 4 Turkey
0 Farrow to Feeder (n sow)
0 Farrow to Finish ( sow)
Other Tvpe of Livestock on the farm: No. of Animals:
A AVn_r-_V 7n/oo - ' Paze I of 4 82- 488

2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): 5.45 : Required Acreage (as listed in the AWMP): 5.2
2.4 Number o lagoon / storage ponds (circle which is applicable): i
2.5 Are subsurface drains present within 100' of any of the application fields? YES or N (please circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES or NQ (please circle one)
2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, MRCS Standards. etc.) (Swine Only)
- or NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited?
What was the date that this facility's land application areas were sited? ' a y ' 9
3. REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
An licants initials
11 One completed and signed original and one copy of the application for General Permit - Animal
/ Waste Operations: V/_JJJ.26�
y 3.2 Two copies of a Reneral location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied: )f/
✓ 3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWIVIP). If the facility
does not have a CAW^1 IP. it must be completed prior to submittal of a general permit application
for animal waste operations.
The CaWMP must include the following components. Some of these components may not
have been required at the time the facilill• it -as certified but should be added to the
CA11IMP for permitting purposes:
✓3.3.1 The IvVaste Utilization Plan (WUP) must include the amount of Plant Available
Nitroeen (PAN) produced and utilized by the facility.
✓3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
✓3.3.3 A map of every field used for land application.
✓ 3.3.4 The sail series present on every land application field.
t/3.3.5 The crops grown on every land application field.
✓3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
.f3.3.7 The P.yti applied to every land application field.
✓3.3.9 The waste application windows for every crop utilized in the WUP.
,,5.3.9 The required MRCS Standard specifications.
/3.3.10 A site schematic.
3.11 Emeraencv Action Plan.
3.3.12 Insect Control Checklist with chosen best management practices noted.
3 3.13 Odor Control Checklist with chosen best management practices noted.
✓�3.14 Mortality Control Checklist with the selected method noted.
f.3.15 Lagoon./storage pond capacity documentation (design. calculations. etc_). Please be
sure to include anv site evaluations, wetland determinations. or hazard classifications
that may be applicable to your facility.
✓3.3.16 Operation and Maintenance Plan.
If your CANV.MP includes any components not shown on this list, please include the
additional components with your submittal.
11v j fJ-
FORM- A WO-r-F 7/7199 Page 2 of 4 82 - 488

Facility Number. 82 - 488
Facility Name: Pork Chop Hill Finishing #6
4,
I,
APPLICANT'S CERTIFICATION:
Z".1 L4
(Land Owner's name listed in question I.2), attest that
� this application for (�A _ - ��n RT11[ f)►x1. [,1 *1 L, -(Facility (Facility name listed in question I.1)
has been reviewed by me and is ac urate and complete to tMe best of my knowledge. I understand that if all required pans of this
application are not completed and that if all req red supporting information and attachments are not included, this application package
will be returned toAnt as ' omplet
Signature -� Date L' /d . 8y a
5. XLXNAGER'S CERTIFICATION: (complete only if different from the Land Owner)
I. (Manager's name listed in question 1.6), attest that this
application for (Facility name Iisted in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included. this application package
will be returned as incomplete_
Signature
Date
THE COMPLETED APPLICATION PACKAGE. INCLUDING ALL SUPPORTING INFORMATION AND ivif? TERL-kLS.
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLIN A DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERI'IITTING UNIT
16171LAJL SERVICE CENTER
RALEIGH, NORTH C AROLINA 27699-1617
TELEPHONE NUNIBER: [phone]
FAX NUIV BER: [phone]
RECavw
'14 120C1u
WATER OUAIM SECTION
11n01 %M*Q
FORTH: AWO-G-E 717/99 Page 3 of 4 82 - 488

Dr-*ZaIO.N OF T ATER QUAI= REt;IO AI. oFTICT-S (If99)
i0) 4-S&11 51-11
ate- V-:=t
,2-10i
77i�.::i
97 5-3i 16
C-a:._— 71N=,.5
R--.. c R=p; --' rr Q S
,'YC Z-1611
(91;) 571-47 0
= [R 19) 7-3-710 2
u
Hs:i az rr +=
.04

ANIMAL WASTE UTILIZATION PLAN
Producer: WILLIAM T. HERRING
Location: P.O. BOX 300
NEWTON GROVE NC 28366
Telephone: [phone]
Type Operation: Existing Feeder to Finish Swine
Number of Animals: 735.00 hogs
(Design Capacity)
STORAGE STRUCTURE: Anaerobic Waste Treatment Lagoon
APPLICATION METHOD: Irrigation
The waste from your animal facility must be land applied at a
specified rate to. prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops
in the fields where the waste is to be .applied.
This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply
more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall be applied to land eroding at less than
5 tons per acre per year. Waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on saturated soils, when it is raining,
or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed
under DWQ regulations.
Page: 1

ANIMAL WASTE UTILIZATION PLAN
5. Wind conditions should also be considered to avoid drift and
downwind odor problems.
6. To maximize the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more than 30
days prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. If
you choose to change methods in the future, you need to revise this
plan. Nutrient levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from your
waste management facility. In some cases you may want to have plant
analysis made, which could allow additional waste to be applied.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
This waste utilization plan, if carried out, meets the requirements
for compliance with 1.5A NCAC 2H .0217 adopted by the Environmental
Management Commission.
AMOUNT OF WASTE PRODUCED .PER YEAR (gallons, ft3, 'tons, etc.)
735 hogs x 1.9 tons waste/hogs/year = 1396.5 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
735 hogs x 2.3 Ibs PAN/hogs/year = 1690.5 lbs. PAN/year
Applying the above amount of waste is a big job. You should plan
time and have appropriate equipment to apply the waste in a timely
manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
Page. 2
s

ANIMAL WASTE IITILIZATION PLAN
TABLE 1: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
----
or
-------
APPLY
RESID.
APPLIC
METH
N
TIME
11568
2
Wa$
BH
5.5
275
0
5.45
1498.75
I
MAR-OCT
11568 1-2
SG �1 150 jfl �5.45 �I$EP-MAY
I
TOTALJ1771.25
Indicates that this field is being overseeded (i.e.
interplanted) or winter annuals follow summer annuals.
NOTE: The applicator is cautioned that P and K may be over applied
while meeting the N requirements. In the future, regulations
may require farmers in some parts of North Carolina to have a
nutrient management plan that addresses all nutrients. This
plan only addresses nitrogen.
Page: 3

ANIMAL WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
See required specification 2.)
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
----
or
-_-___-
APPLY
RESID.
APPLIC
METH
N
TIME
END
Indicates that this field is being overseeded (i.e. interplanted) or
winter annuals follow summer annuals.
In i.nterplanted fields (i.e. small grain, etc, interseeded
in bermudagrass), forage must be removed through grazing,
hay and/or silage_ Where grazing, plants should be grazed
when they reach a height of six to nine inches. Cattle
should be removed when plants are grazed to a height of four
inches. in fields where small grain, etc, is to be removed
for hay or silage, care should be exercised not to let small
grain to reach maturity, especially late in the season (i.e_
April or May). Shading may result if small grain gets too
high and this will definitely interfere with stand of
bermudagrass. This loss of stand will result in reduced
yields and less nitrogen being utilized. Rather than
cutting small grain for hay or silage just before heading as
is the normal situation, you are encouraged to cut the small.
grain earlier. You may want to consider harvesting hay or
silage two to three times during the season, depending on
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late
September or early October. Drilling is recommended over
broadcasting. Bermudagrass should be grazed or mowed to a
height of about two inches before drilling for best results.
Page: 4

ANIMAL WASTE UTILIZATION PLAN
** Acreage figures may exceed total acreage in fields due to
overseeding.
* lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and 2 above:
CROP CODE
CROP
UNITS
PER UNIT
BH
SG
HYBRID BERMUDAGRASS•-Fi4Y
SMALL GRAIN OVERSEEDED
TONS
AC
54
50
TABLE 1
TABLE 2
TOTAL
TOTALS FROM TABLES 1 AND 2
ACRES
LBS AW N USED
5.45
1771.25
0
0
5.45
1771.25
* BALANCE
-80.75
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.
Page: 5

ANIMAL WASTE UTILIZATION PLAN
*** This number must be less than or equal to o in order to fully
utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffers, filter strips along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than
the acres shown in the tables.
See attached map showing the fields to be used for the utilization of
animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient
rich and will require precautionary measures to prevent over application
of nutrients or other elements. Your production facility will produce
approximately 271.95 pounds of plan., available nitrogen per year in the
sludge.
If you remove the sludge every 5 years, you will have approximately 1359.75
pounds of PAN to utilize. Assuming you apply this PAN to hybrid
bermudagrass hayland at the rate of 300 pounds of nitrogen per acre, you
will need 4.5325 acres of land. if you apply the sludge to corn at
the rate of 125 pounds of nitrogen per acre, you will need 10.878 acres
of land. Please be aware that these are only estimates of the PAN and
land needed. Actual requirements could vary by 25% depending on your
sludge waste analysis, soil types, realistic yields, and application
methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the
soil at the time of irrigation such that runoff or ponding occurs. This
rate is limited by initial soil moisture content, soil structure, soil
texture, water droplet size, and organic solids. The application amount
should not exceed the available water holding capacity of the soil at the
time of irrigation nor should the plant available nitrogen applied exceed
the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables 1 and 2. Failure to apply the recommended rates and
Page: 6

ANIMAL WASTE UTILIZATION PLAN
amounts of nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application
rates and amounts.
1
Tract j Field f
I 1
11568 12 I
I 1
11568 1 --2 I
1 I
Soil Type I Crop
waB
B:4
SG
lApplication RatelApplic. Amount
1 (in/hr) (inches)
� I
I 0.60 j *0.96
1 I
I
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations, the application amount shown cannot
be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180.00 days of temporary storage and
the temporary storage must be removed on the average of once every
6.00 months. In no instance should the volume of the waste be stored
in your structure be within the 25 year 24 hour storm storage or one
foot of freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply the
correct rates to the acres shown in Tables 1 and 2. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may
make this plan invalid.
Call your technical specialist after you receive the waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate prior to applying the waste.
NARRATIVE OF OPERATION
Page: 7

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
5. Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
b. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be considered.
Page: 8

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to
wells.
13. Animal waste shall not be a7olied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over. -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly into water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
the site.
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. vegetation such as trees, shrubs, and
other woody species, etc., are limited to areas where considered
appropriaz�e. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 9

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
18. if animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22. Waste shall be tested within 50 days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate -- determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when these
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be
maintained for five (5) years_
23. Dead animals will be disposed of in a manner that meets North
Carolina regulations.
Page: 10

ANIMAL WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm:PORK CHOP HILL FIN±SHING #6
Owner/Manager Agreement
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
North Carolina Division of Water Quality (NCDWQ) before the new
animals are stocked. I (we) also understand that there must be no
discharge of animal waste from this system to surface waters of the
state from a storm event less severe than the 25--year, 24-hour
storm. The approved plan will be filed on -site at the farm office
and at the office of the local Soil and Water Conservation District
and will be available for review by NCDWQ upon request.
Name of Facility Owner: WILLIAM T. HERRING
(Please print)
Signature:
Date:
Name of Manag (If different from owner) : Tam R.of.•.s� �Y►c.
.-r
Signature :ZZ ��, 1 Dm rc,.?�ates-
i
Name of Person Preparing Plan: (Please print)Wilson Spencer
Affiliation:NRCS Phone No.
Address (Agency): 84 County Complex Rd.
Clinton NC 28328
Signature: Date: ~�
Page: 11

ANIMAL WASTE UTILIZATION PLAN
I,
ANIMAL WASTE UTILIZATION AGREEMENT
(Needed only if additional land has to be leased, etc.)
, hereby give
permission to apply animal waste from his Waste Utilization System
on acres of my land for the duration of time shown below.
The field(s) on which waste can be applied are shown on the
attached map.
I understand that this waste contains nitrogen, phosphorous,
potassium, and other trace elements and when properly applied
should not harm my land or crops. I also understand that the use
of waste will reduce my need for commercial fertilizer.
Adjacent Landowner:
Waste Producer:
Technical Representative:
SWCD Representative:
Date:
Date:
Date.
Date:
Term of Agreement: _ _ ,19f to
(Minimum of Ten Years on Cost Shared Items)
(See Required Specification No. 2.)
Page: 12

ANIMAL WASTE UTILIZATION PLAN
STATE OF NORTH CAROLINA
COUNTY OF
1, , a Notary
Public of said County, do hereby certify that
personally appeared before me this day and acknowledged the due
execution of the foregoing instrument.
WITNESS my hand and official seal this day of
, 19
My commission expires
(SEAL)
Notary Public.
Page: 13

ANIMAL WASTE UTILIZATION PLAN
Waste Utilization - Third Party Receiver Agreement
I, hereby agree to apply waste
generated by in a manner that meets the
Waste Utilization Standard (633), or use an alternative waste
utilization system that has been accepted in writing by the
Division of Water Quality.
Third Party Receiver:
Date:
Term of Agreement: to
(Minimum Ten 'Years on Cost -Shared Items)
STATE OF NORTH CAROLINA
COUNTY OF
I, , a Notary
Public of said County, do hereby certify that
personally appeared before me this day and acknowledged the due
execution of the foregoing instrument.
WITNESS my hand and official seal this day of
19
My commission expires
(SEAL)
Notary Public.
Page: 14

�'' br `��►�
',Y
'
'i t-r ` �' Iraliy'::•rti .-:rl'
S-r-`' n- S ��.
r 1,'r'
�`
,'ate
r
.:i
•{`
j
`
r
r r
f�,♦' 111. _jig..
r� i i +■L • `tY <r!r'u,' I r 'N •,+.; t5 r,, .r' r
.. Y}��.:,) \ �;^�w. .. 4 yI d�`r r r' r r�� f� ; rj Cal �k'� ' .��. ,�f,r .'• 1' .r} r .3?.:
` �I. 'y� b,:ir•t. rd _S 9`4} ter + YA''},; - l!' A'•t
S 'i r .f••� i !.pie `!!'� � fJ r �- t '�Ij >r .+ , �, - ...
43
1',1�t✓'- �� \' f/'�'S, �'a/, j- �Jt1'ri'f't I r { f r; �y��2 t.' :� + r . . ,
Y' '� err. .Jr , ', '-Jr • -� •!`� � •",! „�„. � „ 5} i.r � r { �:8'r` r
' �j , j }' � ,'I' '!�, I . ��• y t' ..r �. � �, "Jti : i s � -.' i. st L,.
'�,r�y�V�+ r .5 � , i. 'Y • f ' � 34� I � r' .r r��i ', r � ' J �} r ' t
'err � �{'. '.'.r /' ir�.;'ir r �� a � y.� .L y •r 1�r"' 1. ,+ 5�, \11 ..�. . d 1 '`;
,,6y r � r � y +� r A��L 1 Id r .Et. . +{•i/X1.r �/, •I w
/'r i •:'+,f1t• kr�� _ +• (' Y� 7'' rr, }y 1+4 r1 j�� , r , , ,.
'� ' ,tir r'i .• / '�' � + r r 'E .1 r i rA � 1/'r 1y 'w �_ �j' � '.�. '`r .
' fir• ' %� r__7' �r � 1 t- 1 r 1 rr" �'I � �+rr�r1 � r ri+ r�� rr rq,. :
� '-'r •�� ��:' A
�,r.'+y,�.; �� � �� is i J': ,. .5 • ', r , - 7 �.:,' ' ; � ; ' � . , •�,
r i. .:. _; F'�.r � �. _ �J>. ",3�• ` .A 1 •fir ,` ���',� t ' �•
r 5 4 �• tnr' ,•� � i �� '1( � 1 i r 'Ir i 'r S ✓ I.1. �J r � r
9' �+ •,1' , .tea � '� .� . 4
:r•
�• r r
re
• F. •. ' 1 �yu � d.. yy I ' yr
..,.( . r _ •-•ice.. . .
T� r'
."tF" .-j.t �. ft'r.r r s7-'.'F'',,att �•��} .r •� p `u r' a� .7,��r�
:�;h�.��•J. �.t.' ••�}�.rr. �4;l7r f/r•'"�}`"1:4i `� ';1•..I" 15� '' ';r ,r'
_r' 'i� rEfi� ��,', -i.:� LN Tr�4 t % f y.H� �• ' _ .i l .; �.
' {, t.' �` .1 b r,-���:1M iA1 f,,,r:.�.:,"r '.� ��' '� r ,' I ,,.trr,.Na •4� u f
'h`". r .r,a' ri •,fir. �.4•,,.* , •�.I�Y,. � \ . �. i , ; y.r.-� ,''" r r i�:' _ -�r ,
i ..�' � "a i+ .r�.°J-{..; r f���i• �. , . ��.. it r.�..y' . G.. - y�•o !',. �.';' r ,'/,• ,
��Ai � �•s,,�f � K }•, i,,�L {��} H� yy�•�' 1 � S� T.ti f - 5,.: ' + a �• � '. r ...�
L '� `�rP +r rf 'iL.I 41� � ✓ ',r},.j' P e�:A• -y�*' �` c'�r f. ,. � ',� \ 5t.
'" F�LSr4+' r ><i'r�.Y '�'���r[t y 5�C4 ,etc :` r rF` I � 'r-r• ' _', �� �'�'f +�.
� �•t ��irrn._� id�X:S /Q/f: �iliffi:r-T•�� ' -. - ••F '.- _. 'r ,. �... .. _.� -. _: J.},.. .. .�r[}�:'•,', ^�� .•f�

ly
MAI
W AI 401�
JL
,A
67A
j, jk
iV.
FA
r
A
"
1k,
Jr k WM
to
"to
Fr
0 4Y,
0 .4 1
19.';F "04
4 r Al Owl
.. el,
Ott -
t je
4.1
I oa.
16
4 r
"
4 fir' �- � . '.K.-,-,-. A . � , .&WAT
. o soA:j",
t P�ofPC ""
4
l .A wJ,T
pI r
p AWN A J.
N. 0 son 0
U- PZ4
J.
MAI lull
V4 j
zi
W'.7
W-1 v,
n - Mont
w
9=1w W
V.,
NITIM
Z, L4'

III mmmmm MUFF
m PRI-limm. .
�:;ifif � fi � 1M 11 r � •
� �lIAM 4.�il 'fi ..Y �L J. Ss 1 �.�F�_.e♦'..i•hFY �i�_�i.S.}wLWGY�f�YfiK

�
3
A �
mill
1;
r �,-
»
r
�
-�
Illy
i •
111
1
1
.•11
i `
,...
1
W�'ti
•
;.Y��i!..�Ii ,
� �• ; i f 1
� `f1 p 3 �'+ ( /�� �•" ri•
� .�7� 11'']lµ
J�;� � }�,
1._.j t.r`-J '�r�+ / '� +l
.+• , tf ,!.
� �• ii: i•� '.F.1
.
.�.
„
�.. !
+y'iki, � . ., t/'.:
V�;'}. d�J.Y�y
i.k`i.'7 -tii:
Y 1 �f�
, rp r s•�',e f �i 9� r� + >��
:-lr1 vF.t.: ._k.{'rw} a�iF .iS:�l��
�� ` �, �;,�f�,��
rii�L3�v�..�.'i
�
ti•,«�, A :��,:'�,,,';
, kt'lt'r:,r+%'�.G;a•fa
ti�L' .J: '4�•��nI':
���••'.'�.�•;z; ,=�
t.aa..J ,.. �..��.
• ': ,t1"' fi '�n J IS. isl itHMtTtiil..��. ... •7.. e . 7ti> i"7n,7:.: J+s'_
r r, r.•

t..
rKi
tr'�
•t� �t�+.1"ji1`��„r i• fir'"•��:~'�7J�1���'�
�'rM J'1������." .�. " _ l•`r`i, ]•'ice `�'.•'�}.�'�ti�'..i'S��L?��fS]

��V
�S
.��� rU �Q p�sYl
� 1s �
1
a a 4,! r \
�,.n

Mortality -Management lvlethods
(check which methods) are being, implemented)
J Burial three fee: beneath the surface of the ground within 24 hours after
knowledge of the death. The burial must be at least 300 feet from any flowing
stream or public body of water.
i Rendering at a rendering plant licensed under G.S. I06-169.;
Complete incineration
TI In the case of dead poultry only. placing in a disposal pit of a size and design
aaprove-d by the Deparunent of Agriculture
Q Any method which in the professional opinion of the State Veterinarian would
make possible the salvage of part of a dead animal's value without endanzerinz
human or animal health_ (Written approval of the State Veterinarian must be
attached)
Decdmber 18. 1996

v
operator:
P� � � �
Add or-� Oa,a nt y =
sa.mPson
Distance
to nearest
residence (other
than ownaer):
1 . AVERAGE LIVE WEIGHT (ALW )
Date: 02/24/97
1000.0 feet
0
sows
(farrow to
finish)
Y 1417
lbs. -
O
sows
( farrow to
feeder)
x 522
lhs . -
010
head
(finishing
only)
Y 13.5
lhs . _
O
sows
(farrow tq
wean)
v 433
i hs . _
0
head
/
i wean to feeder)
Y -30
l r L�s , -
Describe other
Total
Average Live Weight
. MINIMUM REQUIRED TREATMFNT VOLUME IMF OF LAGOON
volume = 41850 VS. AUW y Treatment Volume( rF)/lb . AL W
Treatment Volume C'F1/lb- OLM = 1 fF/lh. AI,w
volume = A1850 cubic feat
? . STORAGE VOLUME FOR SLUDGE Arr.r-;MU ?7TON
VO3ume = O.n cubic fast
41, TOTAL DESIGNED VOCUMF
0 lhs
n l bs
4l R50 l bs
0 1 t-, S
0 lhs
0
41R50 lhs
inside top length (feet) --------------------- 120,0
Inside top width (feet) ---------------------- 120.0
Top of dik= elevation (feet) ----------------- aiV n a'
Bottom of lagoon el-vot inn (feet) ------------ 04
Fri: -hoard ( feet ) ----------------------------- 1 n
Side slopes (inside I ag,01 )------------------ "i n t
Total design vniome a-v nT nrisTmi&l form" a
S$/END] SS/EN02 SS/SIDFl SS/STDF2 kENGTH WIDTH [DEPTH
?.0 ?,0 ?.0 0.0 lid 0 114.0 11.0
AREA OF TOO
LENGTH * WIDTH =
i1.4.0 114.0
AREA OF POTTOM
LENGTH * WIDTH =
a8 0 aR 0
12`7% (APFO OF TOP)
00A (&RFA OF BOTTOM)
AREA OF MrDSFCTTnN
LENGTH 1.110TH * 4
Al .n ei _0 20244 ( AREA 07 MTOSE TION * a)
C-1.) , FT, _ [AREA TOP + (A*APEc MTDS,ECTION) + AREA BOTTOM] * DEPTH/6
129% . n 20244 .0 2?04 -n 1 .3
Total OnsiarlSd Volome 4vailahle = 76160 C". FT.

5_ TEMPORARY STORAGE PEQrTREO
DRAINAGE AREA:
Lagoon (too of dike)
Length * Width
120.0 120.0 14d'-)O _O square feet
Buildings ( roof and lot wat-r )
0.0 ro feet Describe this area.
TnTA� DA 14400.0 square feat
Design temporary storage period to be 180 days
5A , Volume of waste prodL ned
Feces & "r i ne production in gal . /day per 13.5 lb. ALW 1.37
Volume = 41e50 IbS _ ALW/135 1 bs _ c,LW * 1 ?7 n.a l /day 1?0 r- yv
Vol r_imo _ M46 oe 1_^, _ or 10220,1 r^i_rhir fact
5R Voir_+me of water
This is the ?rt1oupt of fresh water " ed for washing floor; or �/nlrrmc
of fresh water r_1sed for a flo. sh system Flamb SySt,MS that rpoi-r ^Late?
the invoon water are arroonted for in 5a
Vnli_ima = 0.0 sal long/dey 1&0' H?yF Star=q=/7 aQ e:allon-�
per C'F
Volumo _ Q n cubic feat
5C. Vol_ume of rainfall in excess of evoporation
Use period of time when rainfall eyce?ds evaporation by largest amount
ieo days excess rainfall - 7.0 inches
Volume = 7 _0 in * DA / 12 inches per foot
VoIr_1mo = 8400.0 cubic feet

Sn . Volume of 25 wear - 24 hour storm
volume = 7_0 inches / 12 inches per font * DA
Volume = 8400.8 Cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
SA.
102?0
cubic
feet
58.
4
cuti c
Beet
5C .
8400
cubic
feet
50 _
8400
cubic
feet
TOTAL_ ?7020 cubic feat
6, SUMMARY
Temporary storage
110
clays
Rainfall in excess of
7.0
inches
25 year - 2Q hour
7.0
i Drj es.
1.0
feat
Inside top length___________________________)
120.0
feet
Inside top ur; dth___________________________>
1?0.0
feat
Top of dike Fla,.r?.tion=====__________________>
45.8
feet
Bottom of lagoon
3?.8
fQet
Total required
68870
cu _ ft .
Ar,tu?l design tPnll_!!?1r'====--------------------1
76164
cu ft , �
Seasonal high watertablea elevation (SHWT )===) KD
W o
feet
Stri£3 pumping __________=====I i7•
? Q72
feet
Must to I or = to the SHWT elpv _______--_-) NO K.CS
feat:
Most be ) or = to min. req. treatment el .=)
op.$
fast
Required minimum treatment
41850
c"_ ft .
Volume at stop pumping ei e`Iat ; nor======___=_>
46787
cu . ft .
Start pumpi nn
44.2
feet
Must by at bottom of freeboard $ 2S yr _ rainfall
Actual volume lase '.25 yr .- 24 hr . rA i nfal_ 1 ==)
6770A
Cu- ft .
Volume ?t start pumping Ple"atinn=T-==______>
69610
c u ft ,
Required volume to be
18620
cu _ f t- . �
Actual volume planned to be br,rrPDPr{====______)
21R2?
c1u _ ft . �
Min. thickness nf soil liner when requi red==)
1.2
feet
? DESIGNED FY: W7
a/z Y% DATE:.,
DATE:
NOTE: SEE ATTACHED WASTE !_!T1ri I PTInN p!-AN
COMMENTS:

Operator:PGH #6 Existing County: S?-Oson
Cate:
02/2a/g7
Distance to nearest residence (other than
owmer
1000_0
feet
1. AVERAGE LIVE WETGHT (ALW )
0 srDws (farrow to finish)
w 1417
lbs. =
n
lh�
0 Gnus ( farrow to fleed,?r )
522
lhs -
n
1bS
425 he-ar{ (finishing only)
Y 135
lbs, -
57375
Ibs
0 saws ( farrow to wean)
x 433
lbs . -
n
i hs
0 head (E-1Aan to feeder)
x 0
lhs . -
0
lbs
Describe other
Total.
Average Live Weight =
5737S
1hs
2. MTNTMUM REOUTRFI? TREATMENT VnI_I.IME
OF I_crOnN
Volume = .57375 l hs . ALI.I Y
Tr eat mint Vr) l.,-)me( CF )/ ] h .
4I_i,1
Treatm,:Int_ Volume(C.'F)/lb. AL IJ
=
1 rF/il, al._m
Volume = 57'375 rI_Ih r feet
_ STnParE VOLUME E_ME FnP SU.10GE Arrl_IMI_IL aTTnN
Vr 1 I_EfT1A = r'IJbis feet
d _ TOTAL Dt"SIGNFn VOL LIME
T nsi rio t :,p l ongt h ( fAot 1------------------------ 1
T ns i de t op w idt h( f,�.a t}----------------------- 1, 1. 5. 0
Ton of di ke ej,A%/at i nn (fcPt )------------------
45 .R
Bottom of lagoon ------------ 14
Freeboard (feet) ----------------------------- 1_0
S i de S tones ( i nsi de. 1 arxoon )------------------
Tot a I dac;irtn %/oIi.1me 1,jSing r,ri_srnr.)irial fnrmi_iI
SS/ENDI 4C/FND2 SS/51nF1 SSiSTDF2 I- NrTH I.JTOTH nFPTH
2.0 2.0 ?.n 2_0 1105,p 111 () <4,9
APE& OF TOP
LFN(;TH * WMTH
11F._n 111.0
APEA OF ROT TnM
I Fh!(;TH * WIDTH =
76, _d 71 .4.
1 a47� (AREA nF TrrP 1
�dSzi ( AREA (?F RnTTr)m )
AREA. OF MTpSECTTON
LENrTH WMTH -*. 4
q6 .2 qi .2 -�Snqd (APFA OF MTDSECTION * d }
C.i) FT = [AREA Tnp + ( 4*44PEa + APFA RnTTnM_i AC
12e76 ,() --150g� ,s=i 5455 .0
Total D-?sign-d Volume Available = R8151 (1I FT,

a•
-
�-
U:
4,
Q
C Lr_
G.
C. U
Cf
>.
E
a•
r••
c
Q•
a•
u'
w
�•
a•
>-
a
a.
C' }'
s+
Q'
(JAI
U!
([,
\
(V
-C:
.a
>.
Ui -C
r
5- 4-,
cY
G
t
C.
n
>.
­4
a'
C.
m
•-'-' E
C
C'
4- 0.
},
c
4-'
U,
G
4-
(0
.C".
.0
R
L.
G
f •.
1!, _C.
-C
C,
c�;
c
f- Lt_
Q'
-
-�
4- a
til
'
a-•'
a '
C.
_ l _'
Z' E.
C'
Q
a.
a•
a.
Q
Q G:,
a, a• c
Cr
"C°
(f,
>- s
Q
Q.
ar
Ql
}r
SI rl
�. U'I C',
Cr
1-
►-
s-
.-� �I
4r 4-
G_
�I
rtr
R
ir.
1�
C"
}' .f_`
k
rt
C.
+t, U, t°
rtr
.c 4. c
Q'.
4-
G
co
C.
•FI
W
a•
C.
R•
4-
_
1 C'
o
Cl
C,
(LP
R
. C.
c
(f'
-,
G
C.
('Y
C'
4- > C.
C.
Gr
Gr
C:
2'
0
a'
ZI
}'
Q�
- C�1
' -Ci S-
0)
fr;
G
�J
V
4-' Qr 2
n
a
LO
4-1 rr
4
G
o.
cr, a'
a
C a'
C,
C7
a
..
4- 'i
C r-
r,
_I
![�
N. V
�-1
E
Q:
C, .,, -4
Cr
�.
t
LL
Q'
ir' O
+[
Ri a'
LLI
L1J
,s'
1
F
. I
4-' 3
rt
C
0
a
a.
.1
C•
C-
a..
QI (1,
4-
R'
Q
Q
4 iF
i
E
4-'
Y
s
-C:i !_
G
C
C:
G
LO
,.!~: O
CY
rt1
it YI
K
-C C.
II
II
G.
F-
0
�
of
�
{JI fOy
CCr.
•r+
4-
61
E E
4-
>- r'
E
E
4-
O_
Y-1
0 Q.
C,
Q,
- -
C.
UI
_-
C
Yl
4.
aI
a,
a C,
a'
L 4-
C.
O
Q'
Vi
CE
G
EY,
C,
E
7>
E
F- G a-'
>
E
-
Cl.
G
G
C
LLI
a
?
1-
Q
(YI

5p . Volume of 25 year - 2d hour storm
volume = 7.0 inches / 12 inches per foot * DA
volume = 8050.0 cubic feet
TOTAL PFQUIPED TEMPOPARY STORAGE
5a. 1&011 cubic feat
5g . 0 cubic feet
C. 8050 Cubic feet
5p _ 801,'o Cubic feet
TOTAL 30111 cubic feet
6 SUMMARY
Temporgry storages
190
clays,
Rainfall in excess of eVapnration========-__)
7.0
ipohes
75 year - 2A holly
7.0
i. pcha _.
1.0
fy_ et
Inside too 1p.nln_1t.h=====______________________>
120.n
feet
Tnsid- to Willt.h==='�__�=__;_^_�_�--^-__�___)
110 0
feet
Top of dike
45 S
feet
Bottom of lemon e!swat
na c)
foot
Total required
cu.
ft. :7
Actual design /olUr Q=====__=___---_--_______>
981.41
cu.
ft �
Seasonal high watertahl, alev=tion (SHWT)___)
15_0
feet
Stop pumping
A2 2
fe-t
�
M"sk be ) or = to the SHWT P. l ati� __________�
?e _o
font
must be ) or = to min. req. trcafinent el .�}
40.0
feet
Required minimum treatment �.rn1 �_�m�====____=__)
57?75
c" .
ft
Volume It stork pumping elF�►a.t inn.====____-___)
57AA8
ou _
ft
Start pumping
4A . ?
finet
:x
must be at bottom of freehnard X 25 yr. . rainfall
Actual volume less 25 yr .- 24 hr. . rainfall==)
Pnjoj
00
fit
Volume ?t start pumping eley?tion=====_-_=_-)
805e7
cu
ft
Required volume to be
cu.
ft :x
Actual volume planned to to GirmrFrt=====;____)
221?q
cu
ft, �
Min, thickness of soil liner when requirsd==)
1.4
feet
OEnTGNEn EY: APPPnVED ey:
/ZY�S-7
nATF: [)ATF
NOTE: nFF ATTACHED WASTE I,ITILIZATIQN PUAN
COMMENT4:

OPERAnON & MAIN ENANCE PLAN
Proper lagoon liquid management should b-c- a year-round priority. it is especially
important to manage levels so that you do not have problems during: extended rainy and
wet periods.
Maximum storage capacity should be available in the lagoon for periods when the
receiving crop is dormant (such as wintertime for bermudagiass) or when there are
extended rainy spells such as the thunderstorm season in the summertime. This means
that at the first signs of plant growth in the later winter/early spring, irrigation according to
a farm waste management plan should be done wherever the land L, dry enough to
receive lagoon liquid. This will make storage space available in the lagoon for future wet
periods. In the late summerlearly fall the lagoon should be pumper down to the low
marker (see Figure 2-1) to allow for winter storage. Every effor, should be made to
maintain the lagoon close to the minimum liquid level as long as tho weather and waste
utilization plan will allow it.
Waiting until the lagoon has reached its ma ximurn storage capacity )efore starting to
irrigate does not leave room for storing excess water during extendf d wet periods.
Overflow from the lagoon for any reason except a 25-year, 24-hour storm is a violation of
state law and subject to penalty action.
The routine maintenance of a lagoon invoiv25 the following:
Maintenance of a vegetative cover for t:Ze darn.
Fescue or common berrnudaRrass are the most cornm)n vegetative
covers. The vegetation should be fertilized each y=, if needed, to
maintain a vigorous stand. The amount of fertilizer ;.pplied should be
based on a soils test, but in the event ::tat it is not practical to obtain
a soils test each year, the lagoon embankment and su Tounding areas
should be fertilized with 800 pounds p--- acre of 10-1 ]-10, or
equivalent.
Brush and trees on the ernbankment rr.u3t be controllfd_ This may be
done by mowing, spraying; grazing, clopping, or a combination of
these practices. This should be done at least once a New and
possibly twice in years that. we.? -her conditions are fa'torable for
heavy vegetative growth.
NOTE: if vegetation is controiled by spraying, the herbicide must not be allowed to enter
the lagoon water. Such chemicals could ha.-:n the bacteria in the lad oon that are treating
the waste.
Maintenance inspections of the entire lagcor, should be made during the initial filli:tg of
the lagoon and at least monthly and after major rainy:.L and storm events. Items to be
checked should include, as a minimum, the following:
Waste Inlet Pipes, Recycling Pipes, and Overflow Pipes--Iook for:
l . separation of joints
2. cracks or breaks
3. accumulation of salts o- mine.—als
4. overall condition of picas
zd wtiEr:80 OOeZ tz 'e'43v '3N XUJ Wow

Lagoon surface —look for:
i. undesirable vegetative growth
2, floating or lodged debris
Embankment ---look for:
1. settlement, cracking, or "jug" holes
2. side slope stability ---slumps or bulges
3. wet or dump areas on the back slope
4. erosion due to lack of vegetation or as a result of wave action
5. rodent damage
Larger lagoons may be subject to liner daanage due to wave action c;.used by strong
winds. These waves can erode the lagoon sidewalls, thereby weaker ing the lagoon dam.
A good stand of vegetation will reduce the potential damage caused by wave action. If
wave action causes serious damage to a lagoon sidew all, baffles in 0 a lagoon may be
used to reduce the wave impacts.
Any of these features could lead to erosion and weakening of the dar i. If your lagoon has
any of these features, you should call an appropriate expert familiar with design and
construction of waste lagoons. You may need to provide a ternporarf fix if there is a threat
of a waste discharge. However, a permanent solution should be reviewed by t1 e
technical expert. Any digging into a lagoon darn with heavy equipment is a serious
undertaking with potentially serious consequences a_nd should not be conducted unless
recommended by an appropriate technical e::pe; t.
Transfer Pumps- check for proper operation of:
1. recycling pumps
2. irrigation pumps
Check for leaks, loose fittings, and overa?i pwnp operation. An unu ►wally loud or grinding
noise, or a large amount of. vibration, may indicate t iat the pump is in need or repair or
replacement.
NOTE: Pumping systems should be in5aected and oLerated frequent.y enough so that you
are not completely "surprised" by equipment failure. You should pe form your pumping
system maintenance at a time when your lagoer, is at . s low level. 'this will allow some
safety time should major repairs be require. Having a nearly full lagoon is not the time
to think about switching, repairing , or borrowing pumps. Probably, if your lagoon is full,
your neighbor's lagoon is full also. You s oi-ld consider maintaminl; an inventory of spare
parts or pumps.
Surface water diversion features are de igned to cagy all surface
drainage waters (such as rain -.-ail runoff, roof drainage gutter outlets,
and parking lot runoff) away from your lagoon and other waste
treatment or storage structures. The only water that s}.ould be
coming from your lagoon is that which comes from your flushing
(washing) system pipes and tie rainfall drat hits the lal;oon directly.
You should inspect your diversion system for the following:
L adequate vegetation
2. diversion capacity
3. ridge berm height
S d Lkivtp:RR VMV 17 'now : .- 1a XUJ
: WOHA

Identified problems should be corrected promptly. It is advisable to inspect your system
during or immediately following a heavy rain. If technical assistancu is needed to
determine proper solutions, consult with appropriate experts.
You should record the level of the lagoon just prior to when rain is Predicted, and then
record the level again 4 to 6 hours after the rain (assumes there is no pumping). This will
give you an idea of how much your lagoon level will rise with a cemin rainfall amount
(you must also be recording your rainfall for this to work). Knowing, this should help in
planning irrigation applications and storage. If your lagoon rises excessively, you may
have an inflow problem from a surface water diversion or there may be seepage into the
lagoon from the surrounding land.
Lagoon Operation
Startup:
1. Immediately after construction establish a complete soj cover on bare soil
surfaces to avoid erosion.
2. Fill new lagoon design treatr-ent volume at least half lull of water before
waste loading begins, taking care not tc erode lining or bank slopes.
3. Drainpipes into the lagoon: sh;Duld have a flexible pipe extender on the
end of the pipe to discharge near the bottom of the lagoon during initial
filling or another means of slowing the incoming Ovate- to avoid erosion of
the lining.
4. When possible, begin loading rew lagoons in the spring to maximize
bacterial establishment (due to warmer Heather).
5. It is recommended that a new lagoon be seeded with sludge from a healthy
working swine lagoon in the'amoun: of C.25 percent of the full lagoon
liquid volume. This seeding s;:o•.:ld occcur at least tw) weeks prior to the
addition of wastewater.
6. Maintain a periodic check on thlaper. liquid pH. If the pH falls below
7.0, add agricultural lime at the rate o= l pound per 1(�00 cubic feet of
lagoon liquid volume until t .c pH rises above 7.0. Optimum lagoon liquid
PH is between 7.5 and 8.0.
7. A dark color, lack of bubblhiz. and excessive odor sig-rals inadequate
biological activity. Consultation wi'h a txhnical spec-alist is recommended
if these conditions occur for prolonged periods, especifily during the warm
season.
Loading:
The more frequently and regularly that w-astewater is added to a lagoon, the better the
lagoon will function. Flush systems that wash waste into the lagoon several times daily are
optimum for treatment. Pit recharge systems, in which one or more )uildings are drained
and recharged each day, also work well.
bd Wd":80 000Z TZ 'r%ON ZZTz%Z0iG : 'ON XUA : W0?Jd

Managements
Practice water conservation---mirurnize building water- usage and
spillage from lealcing waterers, broken pipes and wart down through
proper maintenance and water conservation.
Minimize feed wastage and spillage by keeping feeders adjusted. This
will reduce the amount of solids enter-Lng the lagoon
Maintain lagoon liquid level between the permanent storage level and
the full, temporary storage level.
Place visible markers or stakes on the lagoon bank to show the
minimum liquid level and the maximum liquid lever (Figure 2-1).
Start irrigating at the earliest possible date in the spring based on
nutrient requirements and soil moisture so that temporary storage
will be maximized for the sumnmer thunderstorm seascn. Similarly,
irrigate in the late summerlez; Iy falI tc provide maxin►um lagoon
storage for the winter.
The lagoon liquid level should never be -loser than 1 'vot to the lowest
point of the dam or embankment.
Do not pump the lagoon liquid IeveI lc-Aer that the permanent storage
level unless you are removing sludge.
Locate float pump intakes approximates y 18 inches underneath the liquid
surface and as far away from the drLnpipe inlets as p<ssible.
Prevent additions of bedding materials, long -steamed forage or vegetation,
molded feed, plastic syringes, or o&,e: foreign materiz.ls into the lagoon.
Frequently remove solids frc= catch basins at end of ,.'onfinement houses or
wherever they are installed.
Maintain strict vegetation, rodent, and varmint contro. near lagoon edges
Do not allow trees or large bushes to a_ow on lagoon dam or embankment.
Remove sludge from the lagco,n either when the sludg! storage capacity is
full or before it fills 50 perce::t of t1ne permanent storage volume.
If animal production is to be terminateJ, the owner is responsible for
obtaining and implementing a closure plan to eliminate: the possibility of a
pollutant discharge_
Sludge Removal:
Rate of lagoon sludge buildup can be reduced by:
Sd WUS17:60 OBOE iZ '^ON ZZIc.56-: 5 : 'ON xtij : WDU

proper lagoon sizing,
mechanical solids separation cf flushed waste,
gravity settling of flushed waste solids m an appropriately designed basin, or
minimizing feed wastage and spillage.
Lagoon sludge that is removed annually rather tha:i stored Iong term will:
have more nutrients,
have more odor, and
require more land to properly use the nutrients.
Removal techniques:
Hire a custom applicator.
Mix the sludge and lagoon liqu=c with a chopper -agitator impeller
pump through large -bore sp�:nkler irrigation system onto nearby cropland;
and soil incorporate.
Dewater the upper part of lagoon by irrigation onto nearby cropland or
forageland; mix remaining sleege, pump into liquid sledge applicator; haul
and spread onto cropland or fcragelanL; and soil incorporate.
Dewater the upper part of lagoon by i- igation onto nearby cropland or
foragcland; dredge sludge from. lag,00r: with dragline cr sludge barge; berm
an area beside lagoon to receive the sLd;e so that liquids can drain back
into lagoon; allow sludge to dew?tcr; haul and spread ,with manure spreader
onto cropland or forageland; and soil incorporate.
Regardless of the method, you must have tr:- slid,-: material analyzel for waste
constituents just as you would your lagoon water. The sludge will contain different
nutrient and metal values from the liquid. The atmlication of the sludge to fields will be
Iimited by these nutrients as well as any pvzvioius was:t applications to that field and crop
requirement. Waste application rates will lee discussed in detail in Chapter 3.
When removing sludge, you must also pay attenticn nj the liner to prevent damage. Close
attention by the pumper or drag -line operator will ensure that the lagoon liner retrains
intact. If you see soil material or the synthetic, liner material being d sturbed, you should
stop the activity immediately and not resum: until voU are sure that Lie sludge can be
removed without liner injury. If the liner is damaged it must be repaired as soon as
possible.
Sludge removed from the lagoon has a muc higher phosphorus and heavy metal content
than liquid. Because of this it should probably be applies to land with low phosphorus
and metal levels, as indicated by a soil test, and irco..>orated to reduise the chance of
erosion. Note that if the sludge is applied to field: w- h very high so Nest phosphores, it
should be applied only at rates equal to the crop rerno%,al of phosphorus. As with other
wastes, always have your lagoon sludge ana1yzt_,d- for its nutrient value.
The application of sludge will increase the amount of odor at the waste application site.
Extra precaution should be used to observe the wind ci-ection and other conditions which
could increase the concern of neighbors.
9d WUSV:80 0002 1Z '^QM Z'eYG_E,^3i6 : 3E4 Xdzi : WMU

Possible Causes of Lagoon Failure
Lagoon failures result in the unplanned disc ;a.-ge of wastewawr from the structurc. Types
of failures include leakage through the bosom or sides, overtopping, and breach of the
darn_ Assuming proper design and construction, the owner has the :rsponsibility for
ensuring structure safety. Items which may lead to lagoon failures include:
Modification of the lagoon structure --an example is ,he placement of a pipe
in the darn without proper design and construction. (Consult an expert in
lagoon, design before placing any pipes in dams.)
Lagoon liquid levels --high levels are a safety risk.
Failure to inspect and mn dnt,6n the don.
Excess surface water flowing into t;-ie ?moon.
Liner integrity --protect fro.:, inlet pipe scouring, dw Labe during sludge
removal, or rupture from lmx eying lagoon liquid level below groundwater
table.
NOTE: If lagoon water is allowed to ove op :he dam, the moving water will soon cause
gullies to form in the dam. Once this damage starts, it can quickly -;arse a large discharge
of wastewater and possible dam failure.
Ld WU9b :80 000Z T2 '^otJ 22TZ=G2 =6 = i7r� W[

EMERGENCY ACTION PLAN
PHONE NUMBERS
DIVISION OR L1';;TER QU„L ITY (DWQ)
EMERGENCY N1„N"C-P In,ET SERVICES (EMS)
SOIL AND WATER M.S=RVATION DISTRICT (SWCD) _ 91a-S5a-7;c.3
NATURAL RESOURCES CONSE;RV.; T lON SERVICE (NRCS} _gin _5793.-:nc.,3 _
COOPERATIVE EXTGaSION SERVICE (CES) Otto -S1a - 71 Gl -
This plan will be implement=_o' in the even ti,a : wastes from your operation are leaking,
over-, 'lowing or running of f site. You should not wait until wastes reach surface waters
or leave you property to consider that you have a problem. You should make every
erort to ensure that this does not happen. Tis plan should be posted in an accessible
location for all employees at the facility. The following are some action items you should
take.
1 , Stop the release of .va5tes. Depending on the situation, this may ore may not be
possible. SuggesL_d responses to some possible problems are listed belwo.
A. Lacoon overflow -possible solutions are:
a. hdd soii tc oerm to increasa. eeva tion of dam.
b. "limp v'rs=.as to fields at an ace; ptable rate.
c. StOp Ell iio':%,s to the lacoon I! ; ::eCiately.
d. Call a pul.,ping contractor.
e. I`Aake sura r,o sur ace,�,va'.rer is _...eying lagoon.
S. Funo-ff UOM JES -3 CppliCZ!iOil held-YCtlons include:
a. STO.D WaS72 G 'JIIL=_iOri.
b. Create c :lporary diversion 10 com.ain wasta.
c. Ir.corpera -.vast_ to reduce r-.o
d. 'Evalua-ie eliminate the r easy r—i(s) that cause the ru'no�;.
e. E'faiucie W appiication ra'e5 'cr the fields where runoff occurred.
C. Le-akage from. ,",e waste pipes ar:C sprinklers -action include:
a. Stop recyc;e pump.
b. Slop irrita::fln pump.
c. Close valves to eliminate further discharge.
d. Re.Oair c l ie„ks prior to res`ar-%. nc pUr nips.
D, Leakzce ir;,... , :sn SyStem.s, ho',ses, solid separazors-ac:lcn include:
a. S:up recyc'e pump.
b. S_op irriea: o!`i p=�mD.
C. slake 54r_ S:Pno; � occurs.
d.. StCp 2:1 fic,. s in th•e house, T;':5` syS:em5, or solid seoErators.
E. l ceieco H_ .. '-Sse or sidewal; of Paz^On. 0-Seri this is seaPace as opposed
'io:°�irC poke Cossibie ac,ioln:
a_ is a s',c s :" O cr dltcin f"c7-. :r'e eimlbankment to CCtCh all
se p�ac c s� brr ersible _ _ and pump back to !acton.
_^. Vl: 'Dies E _ ..3used by 1✓E.i O'`:'. a:'lirnals, trap or re -move animals and 71i1
ro;an c. c_ ;ct with a clay -y:e soil.
C. f av-3 c C'es5io� ial ev a I L., a e condition of the side .v2ll5 and lagoon
scc as poss,Dle.

2.
3.
4
Assess the extant of the spill and no.e any obvious damages.
a. Did the ),vaste react] any surface
b. Approximaie!y hove much was released and for what dura:ion?
c. Any damage notes, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface wa'ers?
c. Are potable water wells in danger (either on or off the property)?
h. How much reached surface waters?
Contact appropriate agencies.
a. During normal business hours call your DWC! regional o+lice; Prone - -. Ater
hours, emergency number: 919-733-3-942. Your phone call should include: your
name, facility number, telephone number, the details of the incident from item 2
above, the exact IOCSTiOn Of The facility, e location or direction of rnlovenent of
Lhe spill, we'a-zher a,-d conditicns. t ;[e correc-Live measura5 have been
under taken, and the seriousness of -rhe sizution.
b. ]f spill leaves property or enters SUr7ace waters, call local EMS phone number.
c. lns.ruc. EMS to contact local Helaz;ln Deoartrnent.
d. Comae CEs, Phone number - , local _': 1WCD off ice phone numnber - -, and local
NRCS office for advice ltechnicaI assist=.nce phone number - .
if none o; ::.e above vvorks ca!1 9 11 cr _-= Sheriff's Departnnen- cr,d explain you
probien"n ;o tiiier-, and ask the person .o cc^tact the proper ace';cles for you.
Con-aC. -Line con-Lrac--or of your choic zo 'Ciecin repair or proole n to rninimize of' -i-
s ,e dEm.'ace.
1 , L
a. Cont-actors Name: L+ T C7^.5' •=i �v-+1 C ;. �iuk C�ht
b. Con-raCtors Address: �� �S l✓e Grosse .� i �Q _ D�.,� M-C
C. Cori-ractors Phone: 1R9;4 -39":�co
+. Cm-._aC< ,he -Lec*-nical spsciciis: vw'i.o C =C the lagoon. (NRCS, COris'_1:nnC�
Encirneer, E.,c.)
a. Name: Iso-r, 5oe+,
b. Phone: - 5 5 - - r
7• l'"?�lE,i[E�, rriCredurtiC Es adviwad t F;-id EC4itCies to
r� CT T y it ` Gal: ace, -wC:r .:[e S yS7=_ -:'r C , :..SSeSS 4rie wGs.e MI.E .E:Z-:M Ali plan Lo
'.CaE'i MrGCiE 5 L=".il ?!a�5e of as, i+'� I, hc,^.r ei[inC cCclrr.
2

SWINE F.;FiM WASTE MAN; GE.'AENT ODOR CONTROL CNFCKLIS T
Source
Cause
E :,r's __ Minimize Odor Site Specific Frzc-ices
Farmstea•C
Swine procuc'son
VI;e-.'tive or wooded buffers;
i-e-_" rrenGed bast
;raz-;Ces;
{-!"'Gcod _Omer.: and c:r-.r,or. stnse
Ani-.al' :odv surfaces
piryr-tiarv.,t-=vsred anirnals
f }/�-�',zors
Floor s_^aces
Wet-nenurr:ove.sd floors
(ir S.c..__ floors;
lv waterers lotatad over slatted flocrs;
{ ] ?a-ders at hive and of scfid floors;
{ f Scra-- e manure buildup from floors;
{ j `.:--zer-fioor ventilation for dryin,
]Manure calieG:ion, ;its
Urine
Frecuert-nanure removal by flus;,rit
recnar;e,or scrape
Farital c.tomposition
ventilation
Ve ;--la:icr cxaEcs; `ans VoiBaie ;eses: ( -an r :aintenance;
air movement
tndcor s�.:"aCSs .. .-uS: t'✓, '.was' --Own be:WSen ;rou;s Of animals
tanks waetaioa .__VcsCi lagoon ( , • •-_ . tank = ve,
lic,:id wriiies ,ar.ks are fiilind (} _ fiil lines :o near oc
with Ln:i-s„^. ior: vents
F:Us:: aiievs .=.gitallon. LU.r--; wastewater i i .. :CGr ,..:sh With
„,rtvsyanance ve-.::teller,
Pei recnarae ,7Cints A;i:at:on -, ,_c'fc!e: lagoon . �, =xe' :e_nar_' tines ._ near bc7!cr. C,
lk%Ad w^i;e :as art filling :�i:s _ .h anti -sip ;on vents
=` 5:eacr ;;i:atier. c_..r;r sc-p tank Giiiny =_—'- :- ( n.0 _givers
and wrawdcwn
Cu*side grain cpilc_.ic:s A;itatior, _:.;d:; wastewater (] _cz -=vers
or j><n C'.ICn -CXes co^vtyar:tL
+ kc: of _. einzi-,es a: :aycG75
nritaiion cur..: y wastewater
( f Ex:_-z :5scnar;t mint of ;ipes
uncer-eatn !adocn liculc level
I agcon S_r e=Ls
VCia:lie ;25 :^rssionS
___" :a;cCn gq:jic ca=ac y
aioi4::al :xtGy
(i Czr-t z: 'a Yvon StarC,:L ;fDCCtures
a::a::Cn
1 :!i-. L•"•--7 5',�aLCS Oree-tq-vCiu M1.::aliM -
(} azi:aticn when pcn_ir-
( ifs• _=`anicai aeraIlDn
i:.:p2.tCc 'ac ^KI=, ,..._-.!5
_ �- . 'S�'.'! _ :aa Gn ..
1✓ . - =_ - :r, = f �e VS wit-. iiC!e or nc vi-
L'...._
cpera:ion . ess:..-
rn/�_...-� .._2Ke near le;ccn 11 y::ir1 s_-ac!
i -�..'72rn se_. nd-staye I"c_7cn

rake -ark at tasin Partial rricrctial decornpasition
Mixir.b w^iie fiiiin;
AbI:aLICr W.rItn ernpzying
{ } tic-:n or midlevel loading
} Tark eavers
( ) aasin surface mats of solids
O P:-Vern. SioiagiCai ad-:itiws ar Cxi:ars
Se tin; =asin ".."a_e Partial mi.cbiai deconaosition (} =x-trod' drainpipe outlets undernaE:h licuio
Mixing whiie thing level
Acitation wirers emptying () Remove seriled solids regularly
`-ien::re. si_r or s:u0:e %k;itazion «.�sn screecina O Sail infection of slurry(siudges
sp:sad :' oL:la:s Volatile ;,as trrussions ( ) Wash residual manure from spreader after use
( ) Proven biological additives or oxidants
Uncovered manure, slurry Voiarile ;as emissions while drying [) Soil infection of slurry/sludges
or s7cY__ =n ;ieic s_rfac:s O Sail incorporation within 4.3 hours
() Spread in thin uniform layers for rapid drrir.�
(} Fraysn biological additives or oxidants
Clad ar:n>ais Car_asS:;isposition of carcasses
;read ani-.al -is=Csa) Carcass Cec_rnp"i,icn ( ) C_r,.pi..e ccverinc of =arcassas in s ia1 piss
pits (V?'=.per locationicons:r-iction of cis=csal pits
Incinera:=rs Inca -pie:_ =or_ustion ( ) S'-==ncary stack tsurners
S.andina we:_, are nc In ape! ..:airaes [yl' Gra=_ and landscape suci•s rat war_..:ai-s
.ac:ii ;.es Mi-=ziai ey frdn ;aCiiiJes
•L. a . -�.._� cn._ P:--T;y nal':_lned access raaCs ( '•:- access road maintenance
f' m access
AdGi:ianal 1r,icr nz-.ion: Ivaiiabie
Swine tS2r.Wrt .� an Sa..._. „ C2D"v .rule c..' Packet NwSJ-County xension Cente
Swine F. __.::icr ter- =:-cmial Gco. _._:des and remedies, FB,-.0 =a=, 3=et. NCSEJ-3:=
Swine r. oC uc:.gin =eciii^r 'r an_re ?.1ana= Fit lied szr;e- .a;,con T , tamer , EEAE i 2?-38 NCSJ- --- A:
Swine `-oGut:icn Faciii-r Manure Mana;enent. Underfloor Fiuse—La;=c:--rea_•ner.:: C= _ i-29-FE NCSu-aAI
L_,;oon _Psi; and Mena=even:'orUvestsckMarure Treatment and Stara„e. iv;-ca NCSJ-BA
Caiibrat.,... cf. Nler,ure ar..'Wastewater Acciication =—;uiprrlen,, EBAE =a=: Snee:
Ccnt:=iiiny ��crs',rcr-s Swine Suiidin;s; _!^ 33 NCSJ-Swine Extension
=nvirarrnental Assuranc r`rcgrar: N??C Manuel ::C Pork Produces Assoc
C; :inns `:r !: ar�a;in; Sdcr; a reaor frtr-,ne Swine Odor Task Force NCSU A„ i Cornmunica:icrs
huisar-ce =morns in Animai!Manure Marastment: Odors and Fiies; PtiCt C7. iSSS Caniertnce ?rc:esEir.-,s ^:cril:a Cooperative :x-,ersian
! hVe t5S"S 7 =C{�C i rcii r: :+�I$ Ozerp:3l3i). ! fl@ IG�Cui.arllr.:-_r: rrC 'cCrccS :Y LSe SCU,IC iudgi:iciitT Iapplying
cdcrr ,r.._ ,IL') ease. CS p,rac:izzl.
odor ccn:i4l Ba$: Manat^g-man-, =-o-:ices have been r1e.
7
TO M.
5; air©C":J ir�r a: --- (=-)

INSECT CONTROL CHECKLIST POR ANIMAL OPERATIONS
Sc:.. _ Cause . ;.1i='5 Min:'mize Ccor Site Specific Practices
sys:emsl
Fwsh Gvners Accumulation of solids r.;s- sisters is aesi;ned ant c e:gtt�
su�'icientfy to remove accumulated
soilcs from putters as designed.
() Se--cv- brid„ing of accurnuia;ed sciics at
cisc.`.arge
Lagoons and Pits
Crusted Solids
(V IVtairrain lagoons. settling besits and
pits "^+ace past breeding is a;;caren: tc
rrirrimi:a the crusting of solids:c a ttc:.11
of no rnore than 6-$ inches over mere : an
3CII-6 of surface.
Exztssive Vegetative
D:cayin; veGetarbn
, • .nrain vege;ative contrcl aior.^, ;,anics c,
Grow:a
la9ccr.s and ctaer irnp6Lndmers t_
ac_t.=iaticr of decayir G ve,e._rive a e-..
aims water's edge or; ir..pQundme-: s-eri.ne-er.
5ys:ems)
i=eecers
Feed Spillage
Oyes:ter. czera e anc maimair. f.__ syst'-s (e,g.
_nRers and .-3u;rs:.-ini-i-_ tag a,c_-uletian
( ) C.:ean �;_ spillage on a routine :asis (e.;. 7-13 day
zLnn; st.rnmer, .E-3:: -ay ::...el .,-rin„ winter).
S:c;ra^ye
isLCJrnulaucns 0::eet resii.ueS
wi:nin arm aroundd.
;eri-teeter -.f feed St:.r2_t a'ses ny
1�5� •may _:ai^2�e away front sire aric Cr
tin :T
e w±f's Main and si-'Silar hi;' "piS._re ;ryln
� ccus.ni.
(} !r.sGec: :;.r and remove or break __ acccmuiated
s_iies .,.:pit_. S-rips around `e.. s ;t as needed.
An;Mai HoidinS :seas Axvrnulations of animal westes ()=iirnira.e low area that :rap r..cir._re aicn; fences
and feed was:a,e anc s"er locations w;ne-t waste xccu-u!ates and
arc --:S"-;rt�ance by anin-ais is-ini^pai_
O f.'air.;fir fence rcws an.: fiber s:ri.s erg ^d anirsal
hcie:-tl erszs :o n-'inir-i:_
`.r., ar:c rerncve C.
sa:iCs is

_.y Manure Handling Accumulations of animal wastes () Aar-kova spillage on a routine besis lc.,;.7-in day
Sys -erns in:arvvai during summer; 1 5-3D days in;er+al during
wirier) where manure is landed for land appficavon
or disposal,
1) ?rovitla for adequate drainage around manure stockpiies.
{) Irs;.ec. for and remove or break up accumulated wastes
in filter stapes around stockpiles and manure handling
areas as needed_
The issues checked I) pertain to this operation. The landownertntegrator agrees to use sound judgment in applying
insect control measures as practical.
I certify the a=orEmentioned insect control Best Manager -,en: Practices have been reviewed with me.
(La ncowrisr Siyna:ure)
For mere ir.:or^8;tcn rontat;;he f.Otsperative Extension Service, Dc=ar-sn, of r—momalogy, sex a -is, Ncr..: Car:iira State Universiry, Raleigh, N:
Z-7553F-7W:3,
A NIC-1iOvernber 11. ISSES