820427_CORRESPONDENCE_20171231

NORTH CAROLINA
Department of Environmental Qua

Nutrient Management Plan For Animal W
This plan has been prepared for:
Shell Hog Farm
DK Spell
2420 Five Bridge Rd
Clinton. NC 28328
[phone]
03-11-2007
This plan has been wevelop by:
Greer Moore
Clear Run Farms Consulting Services
PO Box 338
Harrells, NC 28444
(910) 532 493
— yw�
Developer Signature
Type of Plan: Nitrogen Only with Manure Only
Owner/Manager/Producer Agreement
I (we) understand and agree to the specifications and the operation and maintenance
procedures established in this nutrient management plan which includes an animal
waste utilization plan for the farm named above. I have read and understand the
Required Specifications concerning animal waste management that are included with
this plan.
n � , 3 ,�, Z
Signature (owner) Date
Signature (manager or producer) Date
This plan meets the minimum standards and specifications of the U.S. Department of
Agriculture - Natural Resources Conservation Service or the standard of practices
adopted by the Soil and Water o6ervation Commission.
Plan Approved By:
it
Technical Specialist Signature Date
464523
Database Version 3.1
1- AUW- (G 1
Date Printed: 03-11-2007 µ Cover Page I'
1n 5 Gc-&P-?Vol

Nutrients applied in accordance with this plan will be supplied from the
following source(s):
Commercial Fertilizer is not included in this plan.
S7
Swine Feeder -Finish Lagoon Liquid waste generated 1,149,480 gals/year
by a 1,240 animal Swine Finishing Lagoon Liquid operation. This
production facility has waste storage capacities of roximate# 180 days.
Estimated Pounds of Plant Available Nitrogen Generated per Year
Broadcast
2648
Incorporated
4547
Injected
5007
1rriEated
2878
Actual PAN Applied
(Pounds)
Actual Volume Applied
(Gallons)
Volume Surplus/Deficit
(Gallons)
Year l
3,633,50
1,451,369
-301,$$9
` Note: In source ID. S means standard source. U means user defined source.
464523 Database Version 3.1 Date Printed: 03- I I -2007 Source Page I of I

i6w Narrative
Spell Farm has regular access to a 3600 gallon honey -wagon and aerway which can be used to broadcast
lagoon .eater onto spray -fields and may also be used to fertilize entire field (including the sub -field
acreage). Sub -field acreage was determined by measuring total field acres, deducting the wetted acreage
from total acreage, then deducting the required set -backs (buffers) from remaining available field
acreage, which then determined the allowable Sub-1 field acreage, available for aerway application.
Greer Moore
Private Technical Specialist
FARM 1S A HAY/GRAZE COMBINATION
Farm is allowed to grave winter crop (small grain overseed). Cows may be brought on winter cover from
10101 three 3/31 ( application window for small grain cover).
CROP YIELDS MUST BE KEPT (COASTAL BERMUDA HAY)
464523 Database Version 3.1 Date Printed: 03-11-2007 Narrative Page 1 of 1

The table shown below provides a summary ofthe crops or rotations included in this plan for each field Realistic
Yield estimates are also provided for each crop in the plan. In addition, the Leaching Index for each field is shown,
where avai fable.
Planned Crops Summary
Tract
Field
Total
Ames
useable
Acres
Leaching
Index (LI)
Soil Series
Crop Sequence
RYE
9846
1
8.30
8.30
NIA
W
Small Grain t)verseed
I.0 Tau
Hybrid Bermudagrass Hay
5.5 Tani
9846
Sub -I
2.88
2.88
NIA
Wagram
SFWW Grain Oversecd
1.0 Tons
i lybrid Bennudagrass Hay
5.5 7 ons
PLAN TOTALS: 1 1.18 11.18
Ll
Potential Leachin
Technical Guidance
2
L,o\� potential to contribute to soluble
None
nutrient leaching below the root zone.
>= 2 &
\1oderate potential to contribute to
Nutrient Management (590) should be planned
<= 10
soluble nutrient leaching below the root
Zo ne.
High potential to contribute to soluble
Nutrient Management (590) should be planned. Other conservation practices that
nutrient leach ing below the root zone.
improve the soils available water holding capacity and improve nutrient use efficiency
> 10
should be considered. Examples are Cover Crops (340) to scavenge nutrients, Sod -Based
Rotations(328), Long -Term trio -Till (778), and edge -of -field practices such as Filter
Strips (393) and Riparian Forest Buffets (391).
4,C4& Y1 W.-, 1 1 fl.t, III I t)M17

The Waste Utilization table shown below summarizes the waste utilization plan for this operation. This plan provides an estimate of the number of acres of
cropland needed to use the nutrients being produced. The plan requires consideration of the realistic yields ofthe crops to be grown, their nutrient requirements,
and proper timing of applications to maximize nutrient uptake.
This table provides an estimate of the amount of nitrogen required by the crop being grown and an estimate of the nitrogen amount being supplied by manure
other by-products, commercial fertilizer and residual from previous crops. An estimate of the quantity of solid and liquid waste that will be applied on each field
order to supply the indicated quantity of nitrogen from each source is also included. A balance of the total manure produced and the total manure applied is
included in the table to ensuze that the plan adequately provides for the utilization of the manure generated by the operation.
musts unitiaauun
toule Year
[
Tract
Field
Sourer
Ill
Soil Series
Taml
Acres
Use.
Acres
Crop
RyE
APPic,
Period
NitrQVT1
PA
Nutrwm
itcgi!
IlbslA)
Comm.
Fen.
Nutrient
Applied
(Ibs1A)
Res,
0bslA)
Applic,
Method
Manurc
PA
Nuirien[
Applied
(listJA)
Liquid
ManurcA
ppbed
(acre)
solid
Manure
Appbod
(acre)
Liquid
Manure
Appbed
(Field)
solid
Manure
Applied
(piety)
ti
1
N
N
F
1000
gal1A
Tons
1000 gals
tons
9W
1
S7
Wag=
8,30
8.30
Small Grain OY4:rseed
1.0 Tons
1011-3131
50
0
0
Irrig.
50
19.97
0.00
165.77
0.01
9846
1
S7
Wagrarn
8.30
8.30
Fivbrid Bermudagrass Hay
5,5 Tonst
311410
'275
0
fl
brig,
275
109.85
0.00
911.72
0.04
9W
Sub-1
S7
Wag=
2,88
2,88
Small Grain Overseed
1.0 Tons
IC/1-MI
so
0
0
Irrig.
50
19.97
0.00
57.52
0.01
9946
Sub-1
S7
agratn
2.88
2.=11ybridrmudagms
Hay
5.5 Tons
3l1-9130
•275
0
0
)trig.
275
109.85
Q.40
316.36
0.0+
Total Applied, 1000 gallons
1,451.37
Total Produced, 1000 gallons
1,149.4
$aiancc, 1000 gallons
-301.8
Total Applied, torts
D.0+
Total Produced, tons
0.01
Balance, tons
0.01
Notes. 1. In the tract column, -- svinbol means ]eased, otherwise, owned. 2. Symbol * means user entered data.
'sion 3
Date Printed: 311 112C. j
WUT Page I )I

The Irrigation Application Factors for each field in this plan are shown in the following table. Infiltration rate varies
with soils_. If applying waste nutrients through an irrigation system, you must apply at a rate that will not result in
nmoff. This table provides the maximum application rate per hour that may be applied to each field selected to
receive wastewater. It also lists the maximum application amount that each field may receive in any one application
event.
Irrigation Application Factors
Tract
Field
Soil Series
Application Rate
(inehwAcw)
Application Amount
(inches)
9W
1
Wagram
0.60
1.0
9846
1 Sub-!
Wagram
1 0.60
1 1.0
4c AC V) Lr,,...... 1) 1 r%-.., n_:..«..a III 1 P9nnT I A V if.,.... + ..r t

The following Lagoon Sludge Nitrogen Lhilizstion table provides an estimate of the number of acres needed for
sludge utilization for the indicated accumulation period. These estimates am based on average nitrogen
concentrations for each source, the number ofanitmis in the facility and the plant available nitrogen application
rates shown in the second column.
Lagoon sludge contains nutrients and organic matter remaining after treatment and application of the effluent. At
clean out, this material must be utilized for amp production and applied at agronomic rates. In most cases, the
priority nutrient is nitrogen but other nutrients including phosphorous, copper and zinc can also be limiting. Since
nutrient levels are generally very high, application of sludge trust be carefully applied.
Sites must first be evaluated for their suitability for sludge application. Ideally, effluent spray fields should not be
used for sludge application. If this is not possible, care should betaken not to load effluent application fields with
high amounts of copper and zinc so that additional effluent cannot be applied. On sites vulnerable to surface water
moving to streams and lakes, phosphorous is a concern. Soils containing very high phosphorous levels may also
be a concern.
Lagoon Sludge Nitrogen Utilization Table
Crop
Maximum
PA-N Rate
Ib/ac
Maximum Sludge
Application Rate
1000 gal/ac
Minimum Acres
5 Years Accumulation
Minimum Acres
10 Years Accumulation
Minimum Acres
t 5 Years Accumulation
Swine Feeder -Finish Lagoon Sludge - Standard
^om 120 bu
150
13.16
15.55
31.09
46.64
,ay 6 ton R,)'.G.
300
26.32
7.77
15.55
23.32
So}ixan 40 bu
160
14,04
14.57
29.15
43.72
_- 464523 Database Version 3.1 �` Date Printed: 03-11-2007 Sludge Page I of I

The Available Waste Storage Capacity table provides an estimate of the number of days -'of storage
capacity available at the end of each month of the plan. Available storage capacity is calculated as the
design storage capacity in days minus the number of days of net storage volume accumulated. The start
date is a value entered by the user and is defined as the date prior to applying nutrients to the first crap in
the plan at which storage volume in the lagoon or holding pond is equal to zero.
Available storage capacity should be greater than or equal to zero and less than or equal to the design
storage capacity of the facility. If the available storage capacity is greater than the design storage
capacity, this indicates thatthe plan calls for the application of nutrients that have not yet accumulated
If available storage capacity is negative, the estimated volume of accumulated waste exceeds the design
storage volume of the structure. Either of these situations indicates that the planned application interval
in the waste utilization plan is inconsistent with the structure's temporary storage capacity.
Available Waste Storafie Capacity
Source Name
Swine Feeder -Finish Lagoon Liquid
Design Storage Capacity (Days)
Start Date
911
18o
Plan Year
Month
Available Storage Cavity (Days)'
1
1
70
1
2
56
1
3
78
1
4
87
1
5
134
1
6
ISO
1
7
180
1
8
l80
1
9
180
1
10
163
1
11
147
1
12
123
* Available Storage Capacity is calculated as of the end of each month.
�_ 464523 Database Version 3.1 - - Date Printed: 03-11-2007 Capacity Page I of 1

Michael F_ Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
October 1, 2004
U.K. Spell
Spell Hog Farm
2420 Five Bridge Road
Clinton NC 28328
Alan W. Klimek, P. E., Director
Division of Water Quality
OCT 15 /_394
OENR - FA*TII OLLE REGIONAL. OFRCE
Subject: Certificate of Coverage No. AWS820427
Spell Hog Farm
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
Dear D.K. Spell:
On June 11, 2004, the North Carolina Division of Water Quality (Division) issued a revised State General
Permit for swine facilities. The General Permit was issued in accordance with the directive of Senate Bill
733 (Session Law 2003-28).
In accordance with your application received on February 27, 2003 and in accordance with the directive
of Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to D.K.
Spell, authorizing the operation of the subject animal waste collection, treatment, storage and land
application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AWS820427 which expires October 1, 2004.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Spell Hog Farm, Iocated in Sampson County, with an animal capacity of no
greater than an annual average of 1240 Feeder to Finish swine and the application to land as specified in
the facility's Certified Animal Waste Management Plan (CAWMP). if this is a Farrow to Wean or
Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are unneeeessary,
they may be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a
rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Since this is a revised State
General Permit, it contains new requirements in addition to most of the conditions contained in the
previous State General Permit. Enclosed for your convenience is a package containing the new and
revised forms used for record keeping and reporting. Please pay careful attention to the record keeping
and monitorinO conditions in this permit.
Aquifer Protection Section —Animal Feeding Operations Unit
1636 Mail Service Center, Raleigh, North Carolina 27699-1638
Phone: [phone] FAX: [phone] Internet: h2o.enr.state.nc.us
An Equal Opportunity/Affirmative Action Employer — 50% Recycled110% Post Consumer Paper
NorthCarolina
Naturally

If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of th facility.'
Per 15A NCAC 2H .0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100 foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Duane Leith at [phone]_
Sincerely,
-�Zd4 /-
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
Fayetteville Regional Office, Aquifer Protection Section
Sampson County Health Department
Sampson County Soil and Water Conservation District
Permit File AWS820427
APS Central Files

0� W A 9 Michael F. Easley, Governor
0 QG William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
ft
Alan W. Klimek, P. E., Director
Division of Water Duality
May I, 2003
D.K. Spell
Spell Hog Farm
2420 Five Bridge Road
Clinton NC 28328,
Subject: Certificate of Coverage No. AWS820427
Spell Hog Farm
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
Dear D.K. Spell:
On April 28, 2003, the North Carolina General Assembly ratified Senate Bill 733 which directs the
Division of Water Quality (Division) to extend the expiration date of the Swine Waste Operation General
Permit AWG100000. Therefore, the General Permit has been re -issued by the Division to extend the
expiration date to October 1, 2004. During the period of this extension the Division will be working with
all interested parties on the development of a new version of the Non -Discharge General Permit.
In accordance with your application received on February 27, 2003 and in accordance with the directive
of Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to D.K.
Spell, authorizing the operation of the subject animal waste collection, treatment, storage and land
application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AWS820427 which expired on April 30, 2003.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Spell Hog Farm, located in Sampson County, with an animal capacity of no
greater than an annual average of 1240 Feeder to Finish swine and the application to land as specified in
the facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or
Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary,
they may be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a
rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until October 1, 2004. Pursuant to this COC, you
are authorized and required to operate the system in confom-tity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property. ��
NG-'D�E1WR
Non -Discharge Permitting Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
Customer Service Center
An Equal Opportunity Action Employer
Intemet httpJ/h2o.enr.state.nc.uVndpu
Telephone [phone] Fax [phone]
Telephone 1-8T7-623-6748
5". recyoled/10% post -consumer paper

Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per NRCS standards a 100 foot separation shall be maintained between water supply wells and any
lagoon or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact J R Joshi at [phone] ext. 363.
Sincerely,
lid,
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
Fayetteville Regional Office, Water Quality Section
Sampson County Health Department
Sampson County Soil and Water Conservation District
Permit File AWS820427
NDPU Files

r
Nutrient Management Plan For Animal. Waste Utilization
08-09-2001
This plan has been prepared for:
Spell Hog Farm
Derwood K. Spell
2420 Five Bridge Road
Clinton, NC 28328
[phone]
This plan has been developed by:
Jeffery Brown
DSWC-FRO
225 Green Street
Suite 714
Fayetteville, NC 28301
[phone]
Type of Plan: Nitrogen Only with Manure Only
Owner/Manager/Producer Agreement
I (we) understand and agree to the specifications and the operation and maintenance
procedures established in this nutrient management plan which includes an animal waste
utilization plan for the farm named above. I have read and understand the Required
Specifications concerning animal waste management that are included with this plan.
Signature (owner) Date
Signature (manager or producer) Date
This plan meets the minimum standards and specifications of the U.S. Department of
Agriculture - Natural Resources Conservation Service or the standard of practices
adopted by the Soil and Water Conservation Commission.
Plan Approved By:
Te nica Sp alist Signature Date
---------------------------------------------•-- -----------------------•---
491261 Database Version 1.06 Date Printed: 08-09-2001 Cover Page 1

Nutrients applied in accordance with this plan will be supplied from the
following source(s):
Commercial Fertilizer is not included in this plan.
S7
Swine Feeder -Finish Lagoon Liquid waste generated 1,149,480 gals/year
by a 1,240 animal Swine Finishing Lagoon Liquid o eration. This
production facility has waste storage capacities of 22proximately 180 days.
Estimated Pounds of Plant Available Nitrogen Generated per Year
Broadcast
2649
Incorporated
4550
Injected
5010
Irrigated
2879
Actual PAN Applied
Year 1
2902
Notes:
in source ID, S means standard source, U means user defined source.
----------------------------•------------------------------•---
491261 Database Version 1.06 Date Printed: 08-09-2001 Source Page I

Narrative
This plan was written for the maximum of 75 lbs. PAN for small grain for winter grazing, The coastal
will be harvested for hay during the surnmer months, and the small grain overseed will be grazed during
the winter. It is important to note the application windows with this cropping system. The last day to
apply to the bermuda is 8-31. The small grain should be applied to in split applications. The first
application to occur between September 15th - October 30th and the second one to occur between
February - March. The small grain should be harvested no later tan hApril 7th. This should not be a
problem since the small grain overseed will be grazed. No application of waste should take place in the
months of November, December, and January.
------------------------------------------------------------- ------------------------
Pmvicw Database Version 1.0c Date Printed: 08-09-2001 Narrative Page 1

The Waste Utilization table shown below summarizes the waste utilization plan for this operation. This plan provides an estimate of the number of acres of -
cropland needed to use the nutrients being produced. The plan requires consideration of the realistic yields of the crops to be grown, their nutrient requirements,
and proper timing of applications to maximize nutrient uptake.
This table provides an estimate of the amount of nitrogen required by the crop being grown and an estimate of the nitrogen amount being supplied by manure or
other by-products, commercial fertilizer and residual from previous crops. An estimate of the quantity of solid and liquid waste that will be applied on each field
in order to supply the indicated quantity of nitrogen from each source is also included.
A balance of the total manure produced and the total manure applied is included in the table to ensure that the plan adequately provides for the utilization of the
manure generated by the operation. Animal operations that generate liquid waste and utilize waste storage facilities (lagoons or holding ponds) may apply more or
less waste in any given year than is annually generated by the facility. In order to determine whether the plan adequately utilizes the waste produced by the
facility, the storage capacity table included in this plan should be reviewed to ensure that the design capacity of the storage facility is not exceeded during the
planning period.
Depending on the requirements of the crop and the nutrient content of the waste, some nutrients will likely be over or under applied if animal waste is being
utilized. Waste should be analyzed before each application cycle and annual soil tests are required if animal waste is being applied. Soil tests should be used to
balance the nutrient application amounts with the realistic yields of the crop to be grown. Nutrient management plans may require that the application of animal
waste be limited so as to prevent over application of phosphorous when excessive levels of this nutrient are detected in a field.
Waste Utilization Table Year 1
Nitrogen I
Conine.
Res.
Manure
Liquid
Solid
Liquid
Solid
PA
Fert,
(tbs/A)
PA
Manure
Manure
Manure
Manure
Nutrient
Nutrient
Nutrient
Applied
Applied
Applied
Applied
Req'd
Applied
Applied
(acre)
(acre)
(Field)
(Field)
Source
TotaI
Use.
RYL'•
Applic.
Appiic.
1000
Tract
Field
I.D.
Soil Series
Acre
Acres
Crop
RYE.
Unit
Period
N
N
N
Method
lbs/A
al/A
tons
1006 gals
tons
9846
1,2
S7
Wa m
$.3
8.3
Cereal/Annual R e
1.5
Tons
*9/15-3/3l
75
01
0
Irri .
75
29.9
0.0
248.2
0.0
O/S, Graze, 417
Harvest
----------------------------------------------------•-•----- -------------- ---------
491261 Database Version 1.06 Date Printed: 08-09-2001 WUT Page I

Waste Utilization Table
Year 1
Tract
Field
Source
I.D.
Soil Series
Total
Acre
Use.
Acres
Crop
RYF
RYE
Unit
Applic.
Period
Nitrogen
PA
Nutrient
Req'd
Comm.
Fert.
Nutrient
Applied
Res.
(lbs/A)
I N
Applic.
I Method
Manure
PA
Nutrient
Applied
Liquid
Manure
Applied
(acre)
Solid
Manure
Applied
(acre)
Liquid
Manure
Applied
(Field)
Solid
Manure
Applied
(Field)
N
N
I lbs1A
1000
I gal/A
tons
1000 gals
tons
9846
1,21
57
I Wagram
1 8.31
8.3
1 Bemtuda grass I lay
5.5
Tons
*311-8/31
' 275
01
0
I Irrig.
1 2751
109.91
0,0
910A
0.0
Lagoon Liquids
Total Applied, 1000 gallons
1,158
'Total Produced, 1000 gallons
1,149
Balance 1000 gallons
.9
Manure Solids
Total Applied, tons
1
0
Total Produced, tons
0
Balance tons
0
Notes: 1. In the tract column, symbol -- means leased, otherwise, owned. 2. Symbol' means user entered data-
----- ----- ------ --- --- -- -- ---
491261 Database Version 1.06 Date Printed: 08-09-2001 WUT Page 2

The irrigation Application Factors for each field in this plan are shown in the following table.
Infiltration rate varies with soils. If applying waste nutrients through an irrigation system, you must
apply at a rate that will not result in runoff. This table provides the maximum application rate per hour
that may be applied to each field selected to receive wastewater. It also lists the maximum application
amount that each field may receive in any one application event.
Irrigation Application Factors
Tract
Field
Soil Series
Application mate
(inche"our)
Application Amaunt
(inches)
9846
1.2
1 Wagrarn
0.60
0.72
--- - - - - --------------------- - - - - ----------- - - - - -- - - - - - - -- -- - - - - --
491261 Database Version 1.06 Date Printed: 08-09-2001 1AF Page 1

The following Lagoon Sludge Nitrogen Utilization table provides an estimate of the number of acres needed for
sludge utilization for the indicated accumulation period. These estimates are based on average nitrogen
concentrations for each source, the number of animals in the facility and the plant available nitrogen application
rates shown in the second column.
Lagoon sludge contains nutrients and organic matter remaining after treatment and application of the effluent. At
clean out, this material must be utilized for crop production and applied at agronomic rates. In most cases, the
priority nutrient is nitrogen but other nutrients including phosphorous, copper and zinc can also be limiting. Since
nutrient levels are generally very high, application of sludge must be carefully applied.
Sites must first be evaluated for their suitability for sludge application. Ideally, effluent spray fields should not be
used for sludge application. If this is not possible, care should be taken not to load effluent application fields with
high amounts of copper and zinc so that additional effluent cannot be applied. On sites vulnerable to surface water
moving to streams and lakes, phosphorous is a concern. Soils containing very high phosphorous levels may also be
a concern.
Lagoon Sludge Nitrogen Utilization Table
Crop
Maximum
PA-N Rate
lb/ac
Maximum Sludge
Application Rate
1000 al/ac
Minimum Acres
5 Years Accumulation
Minimum Acres
1 10 Years Accumulation
Minimum Acres
1 15 Years Accumulation
Swine Feeder -Finish Lagoon Sludge - Standard
Corn 120 bu
150
13-16
15-551
31.09
46-64
Hay 6 ton R.Y.E.
3001
26.32
7.771
15.55
23-32
Soybean 40 bu
160
14.04
14-571
29.15
43.72
--------------------------------------------------------------------- --g---------------
491261 Database Version 1.06 Date Printed: 08-09-200I Sludge Page I

The Available Waste Storage Capacity table provides an estimate of the number of days of storage
capacity available at the end of each month of the plan. Available storage capacity is calculated as the
design storage capacity in days minus the number of days of net storage volume accumulated. The start
date is a value entered by the user and is defined as the date prior to applying nutrients to the first crop in
the plan at which storage volume in the lagoon or holding pond is equal to zero.
Available storage capacity should be greater than or equal to zero and less than or equal to the design
storage capacity of the facility. if the available storage capacity is greater than the design storage
capacity, this indicates that the plan calls for the application of nutrients that have not yet accumulated.
If available storage capacity is negative, the estimated volume of accumulated waste exceeds the design
storage volume of the structure. Either of these situations indicates that the planned application interval
in the waste utilization plan is inconsistent with the structure's temporary storage capacity,
Available Waste Storage Capacity
Source Name
Swine Feeder -Finish Lagoon Liquid
Design Storage Capacity (Days)
Start Date
1 8/31
180
Plan Year
Month
Available Storage Capacity (Days)
1
1
66
1
2
58
1
3
61
1
4
60
1
5
87
1
6
129
1
7
170
1
8
180
1
9
170
1
10
159
1
11
129
1 1
12
98
* Available Storage Capacity is calculated as of the end of each month.
491 261 Database Version I.06 Date Printed: 08-09-2001 Capacity Page 1

Required Specifications For Animal Waste Management
1. Animal waste shall not reach surface waters of the state by runoff, drift,
manmade conveyances, direct application, or direct discharge during
operation or land application. Any discharge of waste that reaches
surface water is prohibited.
2. There must be documentation in the design fold that the producer either
owns or has an agreement for use of adequate land on which to properly
apply the waste. If the producer does not own adequate land to properly
dispose of the waste, he/she shall provide evidence of an agreement with a
landowner, who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner
of the waste production facility to secure an update of the Nutrient
Management Plan when there is a change in the operation, increase in
the number of animals, method of application, receiving crop type, 'or
available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs
for realistic crop yields based upon soil type, available moisture,
historical data, climatic conditions, and level of management, unless
there are regulations that restrict the rate of applications for other
nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre
per year. Waste may be applied to land eroding at more than 5 tons per
acre per year but less than 10 tons per acre per year provided grass filter
strips are installed where runoff leaves the field (see USDA, NRCS Field
Office Technical Guide Standard 393 - Filter Strips).
5. Odors can be reduced by injecting the waste or by disking after waste
application. Waste should not be applied when there is danger of drift
from the land application field.
6. When animal waste is to be applied on acres subject to flooding, waste
will be soil incorporated on conventionally tilled cropland. When waste is
applied to conservation tilled crops or grassland, the waste may be
broadcast provided the application does not occur during a season prone
to flooding (see "Weather and Climate in North Carolina" for guidance).
------------- P -
491261 Database Version 1.06 Date Printed: 08-09-2001 S ecification Pa e 1

7. Liquid waste shall be applied at rates not to exceed the soil infiltration
rate such that runoff does not occur offsite or to surface waters and in a
method which does not cause drift from the site during application. No
ponding should occur in order to control odor and flies.
S. Animal waste shall not be applied to saturated soils, during rainfall
events, or when the soil surface is frozen.
9. Animal waste shall be applied on actively growing -crops in such a
manner that the crop is not covered with waste to a depth that would
inhibit growth. The potential for salt damage from animal waste should
also be considered.
10. Nutrients from waste shall not be applied in fall or winter for spring
planted crops on soils with a high potential for leaching. Waste/nutrient
loading rates on these soils should be held to a minimum and a suitable
winter cover crop planted to take up released nutrients. Waste shall not
be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply
with the following: The outer perimeter of the land area onto which
waste is applied from a lagoon that is a component of a swine farm shall
be at least 50 feet from any residential property boundary and canal.
Animal waste, other than swine waste from facilities sited on or after
October 1, 1995, shall not be applied closer that 25 feet to perennial
waters.
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other
than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and
public right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways,
or wetlands by a discharge or by over -spraying. Animal waste may be
applied to prior converted cropland provided the fields have been
approved as a land application site by a "technical specialist". Animal
waste shall not be applied on grassed waterways that discharge directly
4-91261 Database Version 1.06 Date Printed: 08-09-2001 Specification Page 2

into water courses, and on other grassed waterways, waste shall be
applied ar agronomic rates in a manner that causes not runoff or drift
from site.
16. Domestic and industrial waste from washdown facilities, showers, toilets,
sinks, etc., shall not be discharged into the animal waste management
system.
17. A protective cover of appropriate vegetation will be established on all
disturbed areas (lagoon embankments, berms, pipe runs, etc.). Areas
shall be fenced, as necessary, to protect the vegetation. Vegetation such
as trees, shrubs, and other woody species, etc., are limited to areas where
considered appropriate. Lagoon areas should be kept mowed and
accessible. Berms and structures should be inspected regularly for
evidence of erosion, leakage, or discharge.
18. If animal production at the facility is to be suspended or terminated, the
owner is responsible for obtaining and implementing a "closure plan"
which will eliminate the possibility of an illegal discharge, pollution, and
erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected
on a regular basis to prevent breakdowns, leaks, and spills. A regular
maintenance checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other
crops for direct human consumption. However, if animal waste is used
on crops for direct human consumption, it should only be applied
pre -plant with no further applications of animal waste during the crop
season.
21. Highly visible markers shall be installed to mark the top and bottom
elevations of the temporary storage (pumping volume) of all waste
treatment lagoons. Pumping shall be managed to maintain the liquid
level between the markers. A marker will be required to mark the
maximum storage volume for waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested
at least annually at crop sites where waste products are applied.
----------------------------- --------------------------------p----------g - --
491261 Database Version 1.06 Date Printed: 08-09-2001 Specification Pa e 3

Nitrogen shall be the rate -determining nutrient, unless other restrictions
require waste to be applied based on other nutrients, resulting in a lower
application rate than a nitrogen based rate. Zinc and copper levels in the
soils shall be monitored and alternative crop sites shall be used when
these metals approach excessive levels. pH shall be adjusted and
maintained for optimum crop production. Soil and waste analysis
records shall be kept for a minimum of five years. Poultry dry waste
application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a
minimum of five years.
23. Dead animals will be disposed of in a manner that meets North Carolina
regulations.
----------------------------------------.----------------------------
491261 Database Version 1.06 Date Printed: 08-09-2001 Specification Page 4

Crop Notes
The following crop note applies to field(s): 1,2
Bermudagrass Coastal Plain, Mineral Soil, Moderately Well Drained.
Adaptation: Well -adapted.
In the Coastal Plain, hybrid bermudagrass sprigs can be planted Mar. l to Mar. 31. Cover sprigs 1" to 3"
deep (1.5" optimal). Sprigs should be planted quickly after digging and not allowed to dry in sun and
wind. For Coastal and Tifton 78 plant at least 10 bu/ac in 3' rows, spaced '2' to 3' in the row. Generally a
rate of 30 bu/ac is satisfactory to produce full groundcover in one or two years under good growing
coriditions. Tifton 44 spreads slowly, so use at least 40 bu/ac in 1.5' to 2' rows spaced 1' to 1.5' in row.
For broadcastidisked-in sprigs use about 60 bu/ac. Soil test for the'amounts of lime, phosphorus,
potassium and micronutrients to apply preplant and for annual maintenance. Apply 60 to 100 lb/ac N in
the establishment year in split applications in April and July. For established stands apply 180 to 240
lb/ac N annually in split applications, usually in April and following the first and second hay cuts.
Reduce N rates by 25% for grazing. Refer to NCSU Technical Bulletin 305 Production and Utilization
of Pastures and Forages in North Carolina for more information or consult your regional agronomist or
extension agent for assistance.
The following crop note applies to field(s): 1,2
Cereal/Annual Rye Overseeded — Grazed
CEREAL RYE
The cereal rye should be planted by October 15 to provide the best opportunity to get winter growth- The
most consistent stands are obtained from drilling rye into short (less than 3 inches tall) bermudagrass sod.
If drilling is not possible, the seeds may be broadcast on short bermuda sod followed by a light
cultivation with a disc or tillage implement. The seeding rate for broadcast planting of seeds should be
1.5 times the rate for drilled seeds. The last application of animal waste is to be applied to the bermuda
prior to August 31. An application of 501bs/acre of Plant Available N (PAN) may be applied between
September 15 and October 30. An additional 50 lbs.acre of PAN may be applied in February -March. If
rye growth is harvested on time and does not significantly shade the bermuda, PAN rates for the
subsequent bermuda crop are based on realistic yields of bermuda. A harvest is required prior to beading
or April 7, which ever comes first. This is necessary to minimize the potential for shading bermuda and
reducing its yields. The PAN rate for grazed systems with bermuda overseeded with cereal rye must be
reduced by 25%.
ANNUAL RYEGRASS
Annual ryegrass should be planted by October 15 to provide the best opportunity to get winter growth.
The most consistent stands are obtained from drilling ryegrass into short (less than 3 inches tall)
bermudagrass sod. If drilling is not possible, the seeds may be broadcast on short Bermuda sod followed
by a light cultivation with a disc or tillage implement. The seeding rate for broadcast planting of seeds
should be 1.5 times the rate for drilled seeds. The last application of animal waste is to be applied to the
bermuda prior to August 31. An application of 50 lbs/acre of PAN may be applied between September
15 and October 30. An additional 50 lbs. acre of PAN may be applied in February -March. If additional
PAIN is applied to the ryegrass in April -May, the PAN rate for the bermuda must be reduced by a
----------------------------------------------------- --------------------
491261 Database Version 1.0E Date Printed: 08-09-2001 Crop Note Page 1
• JI

corresponding amount. This is necessary because ryegrass growth during April -May will reduce
bermuda yields and shorten the -time bermuda can fully utilize the N. A harvest is required by heading or
April 7, which ever comes first to prevent shading of emerging bermuda during April -May period. To
favor the production of the Bermuda, additional harvests of ryegrass will be required when the ryegrass
canopy.reaches 12 to 15 inches height. The PAN rate for grazed systems with bermuda overseeded with
annual ryegrass must be reduced by 25%,
-----------------------— ---------------------------------------------
491261 Database Version 1.0! Date Printed: 08-09-2001 CropNote Page 2

. Ov.
MON
t
ilk
T
$a'
I- A'. .4-,
AR
Oc
%ty. �,r
' U
tt t . M r j, ;-I, . �' ti,
15i.7
"
t t
:AIV
41
l e!ll
ir
Yl!
t AL 14:,
A
�qg:
va
N -m
. , �!ic ..
I. 1, - )i, % N� J: A* _ ;��. �,, - �• l•'.a� _I'� �; �, "'� •,•_:l<rr.1 ^: :1{�••�`' }r�� ?. _(:., ;�. `_,.... . -r«' y7• .1 �r n'� or. �,r::. ",• : �, . .
�6 k-.t
;;A 4
tl
"I"n '111I
- jAi"•-,V4
T'
iN lil"lef P,ivq Vi lkAl
6, Any
?
54W 9i
- NO,

Nutrient Management Plan For Animal Waste Utilization
08-09-2001
This plan has been prepared for:
Spell Hog Farm
Derwood K Spell
2420 Five Bridge Road
Clinton, NC 28328
[phone]
This plan has been developed by:
Jeffery Brown
DSWC-FRO
225 Green Street
Suite 714
Fayetteville, NC 28301
[phone]
Type of Plan: Nitrogen Only with Manure Only
Own er/Manager/Producer Agreement
I (we) understand and agree to the specifications and the operation and maintenance
procedures established in this nutrient management plan which includes an animal waste
utilization plan for the farm named above. I have read and understand the Required
Specifications concerning animal waste management that are included with this plan.
A �-w
Signature (owner)
Signature (manager or producer)
9-31-0
Date
Date
This plan meets the minimum standards and specifications of the U.S. Department of
Agriculture - Natural Resources Conservation Service or the standard of practices
adopted by the Soil and Water Conservation Commission.
Plan Approved By:
Te nica Sp lalist Signature Date
- - - - --------------------------------------------- - - - - -g--- - - - - --
491261 Database Version 1.06 Date Printed: 08-09-2001 Cover Page 1

Nutrients applied in accordance with this plan will be supplied from the
following source(s):
Commercial Fertilizer is not included in this plan.
S7
Swine Feeder -Finish La oon Liquid waste Zenerated 1,149,480 als/ ear
by a 1,240 animal Swine Finishing Lagoon Liquid operation. This
roduction facility has waste storage capacities of ap2roximately 180 days.
Estimated Pounds of Plant Available Nitrogen Generated per Year
Broadcast
2649
Incorporated
4550
Injected
5010
Irrigated
2879
Actual PAN Applied
Year 1
2902
Notes:
In source ID, S means standard source, U means user defined source.
---------------------------------------------------------------------------g---------
491261 Database Version 1.06 Date Printed: 08-09-2001 Source Page I

Narrative
This plan was written for the maximum of 75 lbs. PAN for small grain for winter grazing. The coastal
will be harvested for hay during the summer months, and the small grain overseed will be grazed during
the winter. It is important to note the application windows with this cropping system. The last day to
apply to the bermuda is 8-31. The small grain should be applied to in split applications. The first
application to occur between September 15th - October 30th and the second one to occur between
February - March. The small grain should be harvested no later than April 7th. This should not be a
problem since the small grain overseed will be grazed. No application of waste should take place in the
months of November, December, and January.
-----------------------------•----•-------------- -----
Prvnew Database Version 1.0f Date Printed: 08-09-2001 Narrative Page 1

The Waste Utilization table shown below summarizes the waste utilization plan for this operation. This plan provides an estimate of the number of acres of -
cropland needed to use the nutrients being produced. The plan requires consideration of the realistic yields of the crops to be grown, their nutrient requirements,
and proper timing of applications to maximize nutrient uptake.
This table provides an estimate of the amount of nitrogen required by the crop being grown and an estimate of the nitrogen amount being supplicd by manure or
other by-products, commercial fertilizer and residual from previous crops. An estimate of the quantity of solid and liquid waste that will be applied on each field
in order to supply the indicated quantity of nitrogen from each source is also included.
A balance of the total manure produced and the total manure applied is included in the table to ensure that the plan adequately provides for the utilization of the
manure generated by the operation. Animal operations that generate liquid waste and utilize waste storage facilities (lagoons or holding ponds) may apply more or
less waste in any given year than is annually generated by the facility. In order to determine whether the plan adequately utilizes the waste produced by the
facility, the storage capacity table included in this plan should be reviewed to ensure that the design capacity of the storage facility is not exceeded during the
planning period.
Depending on the requirements of the crop and the nutrient content of the waste, some nutrients will likely be over or under applied if animal waste is being
utilized. Waste should be analyzed before each application cycle and annual soil tests are required if animal waste is being applied. Soil tests should be used to
balance the nutrient application amounts with the realistic yields of the crop to be grown. Nutrient management plans may require that the application of animal
waste be limited so as to prevent over application of phosphorous when excessive levels of this nutrient are detected in a field.
Waste Utilization Table Year 1
Nitrogen
Comm.
Res-
Manure
Liquid
Solid
Liquid
Solid
NA
Fert.
(lbs/A)
PA
Manure
!Manure
Manure
Manure
Nutrient
Nutrient
Nutrient
Applied
Applied
Applied
Applied
Req'd
Applied
Applied
(acre)
(acre)
(field)
(Field)
Source
'total
Use.
RYE
Applic,
Applic.
1i1fl0
Tract
I field
1.D.
I Soil Series
Acre
Acres
Crop
RYE
Unit
A Period
N
N
N
Method
lbs/A
RaIIA
I tons
1004 ants
tons
9846
1 1,2
S7
I Wo ram
8.3
8.3
Cereal/Annual Rye
L5
Tons
*9115.3/31
75
0
0
Irri .
75
29.9
0.0
248.2
0.0
O/S, Graze, 4n
Harvest
----------------------------------------------------------•------------------------------------------------------------------
491261 Database Version 1.06 pate Printed: 08-09-2001 Wt1T Page 1

Waste Utilization Table
Year 1
Tract
I Field
Source
I.D.
Soil Series
Total
Acre
Use.
I Acres
Crop
RYE
RYE
Unit
Applic.
Period
Nitrogen
PA
Nutrient
Req'd
Comm.
Fert.
Nutrient
Applied
Res,
QbslA)
I N
Applic.
I Methad
Manure
PA
Nutrient
Applied
Liquid
Manure
Applied
(acre)
Solid
Manure
Applied
(acre)
Liquid
Manure
Applied
(Meld)
Solid
Manure
Applied
(Field)
N
N
I lbs1A
1000
I Ral/A
tons
1000 gals
tons
99461
1,21
S71
Wa gram
1 8.31
8.3
1 Bermuda ss [lay
5.5
1 Tons
1 *3/1-8131
1* 2751
01
0
1 Irrig.
1 2751
109.81
0.01
910.1
0.0
Lagoon Liquids
Total Applied, 1000 Rallons
1,158
Total Produced, 1000 gallons
1,149
Balance 1000 Rallons
-9
Manure Solids
Total Aeplied, tons
0
Total Produced, tons
0
Balance tons
I
1 0
Notes: 1. In the tract column, symbol — means leased, otherwise, owned. 2. Symbol * means user entered data.
-- -------------------------------------------------------------- -----•----- -- ----------------
491261 Database Version 1,06 Date Printed: 08-09-2001 WUT Page 2

The Irrigation Application Factors for each field in this plan are shown in the following table.
Infiltration rate varies with soils, If applying waste nutrients through an irrigation system, you must
apply at a rate that will not result in runoff. This table provides the maximum application rate per hour
that may be applied to each field selected to receive wastewater. It also lists the maximum application
amount that each field may receive in any one application event.
Irrigation Application Factors
Tract
Field
Soil series
Application Rate
inches/hour
Application Amount
(inches)
9846
1,2
Wagrarn
0.60
0.72
---•------------------------------------------------ ----- --------
491261 Database Version 1.06 Date Printed: 08-09-2001 IAF Page 1

The following Lagoon Sludge Nitrogen Utilization table provides an estimate of the number of acres needed for
sludge utilization for the indicated accumulation period. These estimates are based on average nitrogen
concentrations for each source, the number of animals in the facility and the plant available nitrogen application
rates shown in the second column.
Lagoon sludge contains nutrients and organic matter remaining after treatment and application of the effluent. At
clean out, this material must be utilized for crop production and applied at agronomic rates. In most cases, the
priority nutrient is nitrogen but other nutrients including phosphorous, copper and zinc can also be limiting. Since
nutrient levels are generally very high, application of sludge must be carefully applied.
Sites must first be evaluated for their suitability for sludge application. Ideally, effluent spray fields should not be
used for sludge application. If this is not possible, care should be taken not to load effluent application fields with
high amounts of copper and zinc so that additional effluent cannot be applied. On sites vulnerable to surface water
moving to streams and lakes, phosphorous is a concern. Soils containing very high phosphorous levels may also be
a concern.
Lagoon Sludge Nitrogen Utilization Table
Crop
Maximum
PA-N Rate
lb/ac
Maximum Sludge
Application Rate
1000 al/ac
Minimum Acres
5 Years Accumulation
Minimum Acres
10 Years Accumulation
Minimum Acres
15 Years Accumulation
Swine Feeder -Finish Lagoon Sludge - Standard
Corn 120 bu
1501
13.16
15.55
3LO91
46.64
Hay 6 ton RY.E.
3001
26.32
7.7-71
15.55
23.32
5oybem 40 bu
160
14.04
14.57
29.15
43.72
--------------------------------------- -••-----------------------------------g------------
491261 Database Version 1.06 Date Printed: 08-09-2001 Sludge Page 1

The Available Waste Storage Capacity table provides an estimate of the number of days of storage
capacity available at the end of each month of the plan. Available storage capacity is calculated as the
design storage capacity in days minus the number of days of net storage volume accumulated. The start
date is a value entered by the user and is defined as the date prior to applying nutrients to the first crop in
the plan at which storage volume in the lagoon or holding pond is equal to zero.
Available storage capacity should be greater than or equal to zero and less than or equal to the design
storage capacity of the facility. if the available storage capacity is greater than the design storage
capacity, this indicates that the plan calls for the application of nutrients that have not yet accumulated.
If available storage capacity is negative, the estimated volume of accumulated waste exceeds the design
storage volume of the structure. Either of these situations indicates that the planned application interval
in the waste utilization plan is inconsistent with the structure's temporary storage capacity.
Available Waste Storage Capacity
Source Name
Swine Feeder -Finish Lagoon Liquid
Design Storage Capacity (Days)
Start Date
1 8/31
180
Plan Year
Month
Available Storage Capacity (Days)
1
1
66
1
2
58
1
3
61
1
4
60
1
5
87
1
6
129
1
7
170
I
8
180
1
9
170
1
10
159
1
11
129
1
12
98
* Available Storage Capacity is calculated as of the end of each month.
--- ------------------------------------------------------------------------------
491261 Database Version 1.06 Date Printed: 08-09-2001 Capacity Page I

Required Specifications For Animal Waste Management
1. Animal waste shall not reach surface waters of the state by runoff, drift,
manmade conveyances, direct application, or direct discharge during
operation or land application. Any discharge of waste that reaches
surface water is prohibited.
2. There must be documentation in the design fold that the producer either
owns or has an agreement for use of adequate land on which to properly
apply the waste. If the producer does not own adequate land to properly
dispose of the waste, he/she shall provide evidence of an agreement with a
landowner, who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner
of the waste production facility to secure an update of the Nutrient
Management Plan when there is a change in the operation, increase in
the number of animals, method of application, receiving crop type, or
available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs
for realistic crop yields based upon soil type, available moisture,
historical data, climatic conditions, and level of management, unless
there are regulations that restrict the rate of applications for other
nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre
per year. Waste may be applied to land eroding at more than 5 tons per
acre per year but less than 10 tons per acre per year provided grass filter
strips are installed where runoff leaves the field (see USDA, NRCS Field
Office Technical Guide Standard 393 - Filter Strips).
5. Odors can be reduced by injecting the waste or by disking after waste
application. Waste should not be applied when there is danger of drift
from the land application field.
6. When animal waste is to be applied on acres subject to flooding, waste
will be soil incorporated on conventionally tilled cropland. When waste is
applied to conservation tilled crops or grassland, the waste may be
broadcast provided the application does not occur during a season prone
to flooding (see "Weather and Climate in North Carolina" for guidance).
----------------------------------------------------------------------------- --------
491261 Database Version 1.06 Date Printed: 08-09-2001 Specification Page 1

7. Liquid waste shall be applied at rates not to exceed the soil infiltration
rate such that runoff does not occur offsite or to surface waters and in a
method which does not cause drift from the site during application. No
ponding should occur in order to control odor and flies.
S. Animal waste shall not be applied to saturated soils, during rainfall
events, or when the soil surface is frozen.
9. Animal waste shall be applied on actively growing -crops in such a
manner that the crop is not covered with waste to a depth that would
inhibit growth. The potential for salt damage from animal waste should
also be considered.
10. Nutrients from waste shall not be applied in faU or winter for spring
planted crops on soils with a high potential for leaching. Waste/nutrient
loading rates on these soils should be held to a minimum and a suitable
winter cover crop planted to take up released nutrients. Waste shall not
be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11. Any new swine facility sited on or after October 1,1995 shall comply
with the following: The outer perimeter of the land area onto which
waste is applied from a lagoon that is a component of a swine farm shall
be at least 50 feet from any residential property boundary and canal.
Animal waste, other than swine waste from facilities sited on or after
October 1, 1995, shall not be applied closer that 25 feet to perennial
waters.
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other
than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and
public right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways,
or wetlands by a discharge or by over -spraying. Animal waste may be
applied to prior converted cropland provided the fields have been
approved as a land application site by a "technical specialist". Animal
waste shall not be applied on grassed waterways that discharge directly
---------------------- ---------------------------------------------------
491261 Database Version I.06 Date Printed: 08-09-2001 Specification Page 2

into water courses, and on other grassed waterways, waste shall be
applied ar agronomic rates in a manner that causes not runoff or drift
from site.
16. Domestic and industrial waste from washdown facilities, showers, toilets,
sinks, etc., shall not be discharged into the animal waste management
system.
17. A protective cover of appropriate vegetation will be established on all
disturbed areas (lagoon embankments, berms, pipe runs, etc.). Areas
shall be fenced, as necessary, to protect the vegetation. Vegetation such
as trees, shrubs, and other woody species, etc., are limited to areas where
considered appropriate. Lagoon areas should be kept mowed and
accessible. Berms and structures should be inspected regularly for
evidence of erosion, leakage, or discharge.
18. If animal production at the facility is to be suspended or terminated, the
owner is responsible for obtaining and implementing a "closure plan"
which will eliminate the possibility of an illegal discharge, pollution, and
erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected
on a regular basis to prevent breakdowns, leaks, and spills. A regular
maintenance checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other
crops for direct human consumption. However, if animal waste is used
on crops for direct human consumption, it should only be applied
pre -plant with no further applications of animal waste during the crop
season.
21. Highly visible markers shall be installed to mark the top and bottom
elevations of the temporary storage (pumping volume) of all waste
treatment lagoons. Pumping shall be managed to maintain the liquid
level between the markers. A marker will be required to mark the
maximum storage volume for waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested
at least annually at crop sites where waste products are applied.
--------------- -- -----------------------------------------------------------
491261 Database Version 1.06 Date Printed: 08-09-2001 Specification Page 3

Nitrogen shall be the rate -determining nutrient, unless other restrictions
require waste to be applied based on other nutrients, resulting in a lower
application rate than a nitrogen based rate. Zinc and copper levels in the
soils shall be monitored and alternative crop sites shall be used when
these metals approach excessive levels. pH shall be adjusted and
maintained for optimum crop production. Soil and waste analysis
records shall be kept for a minimum of five years. Poultry dry waste
application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a
minimum of five years.
23. Dead animals will be disposed of in a manner that meets North Carolina
regulations.
------------ -------------------------------------------------------
491261 Database Version 1.06 Date Printed: 08-09-2001 Specification Page 4

Crop Notes
The following crop note applies to field(s): 1,2
Bermudagrass Coastal Plain, Mineral Soil, Moderately Well Drained.
Adaptation: Well -adapted.
In the Coastal Plain, hybrid bermudagrass sprigs can be planted Mar. 1 to Mar. 31. Cover sprigs 1" to 3"
deep (1.5" optimal). Sprigs should be planted quickly after digging and not allowed to dry in sun and
wind. For Coastal and Tifton 78 plant at least 10 bu/ac in 3' rows, spaced 2' to 3' in the row. Generally a
rate of 30 bu/ac is satisfactory to produce full groundcover in one or two years under good growing
conditions. Tifton 44 spreads slowly, so use at least 40 bu/ac in 1.5' to 2' rows spaced 1' to 1.5' in row.
For broadcast/disked-in sprigs use about 60 bulac. Soil test for the amounts of lime, phosphorus,
potassium and micronutrients to apply preplant and for annual maintenance. Apply 60 to 100 lb/ac N in
the establishment year in split applications in April and July. For established stands apply 180 to 240
lb/ac N annually in split applications, usually in April and following the first and second hay cuts.
Reduce N rates by 25% for grazing. Refer to NCSU Technical Bulletin 305 Production and Utilization
of Pastures and Forages in North Carolina for more information or consult your regional agronomist or
extension agent for assistance-
The following crop note applies to field(s): 1,2
Cereal/Annual Rye Overseeded — Grazed
CEREAL RYE
The cereal rye should be planted by October 15 to provide the best opportunity to get winter growth. The
most consistent stands are obtained frorn drilling rye into short (less than 3 inches tall) bermudagrass sod.
If drilling is not possible, the seeds may be broadcast on short Bermuda sod followed by a light
cultivation with a disc or tillage implement. The seeding rate for broadcast planting of seeds should be
1.5 times the rate for drilled seeds. The last application of animal waste is to be applied to the bermuda
prior to August 31. An application of 50 lbs/acre of Plant Available N (PAN) may be applied between
September 15 and October 30. An additional 50 lbs.acre of PAN may be applied in February -March. If
rye growth is harvested on time and does not significantly shade the bermuda, PAN rates for the
subsequent bermuda crop are based on realistic yields of bermuda- A harvest is required prior to heading
or April 7, which ever comes first. This is necessary to minimize the potential for shading bermuda and
reducing its yields. The PAN rate for grazed systems with Bermuda overseeded with cereal rye must be
reduced by 25%.
ANNUAL RYEGRASS
Annual ryegrass should be planted by October 15 to provide the best opportunity to get winter growth.
The most consistent stands are obtained from drilling ryegrass into short (less than 3 inches tall)
bermudagrass sod. If drilling is not possible, the seeds may be broadcast on short bermuda sod followed
by a light cultivation with a disc or tillage implement. The seeding rate for broadcast planting of seeds
should be 1.5 times the rate for drilled seeds. The last application of animal waste is to be applied to the
bermuda prior to August 31. An application of 50 lbs/acre of PAN may be applied between September
15 and October 30- An additional 50 lbs. acre of PAN may be applied in February -March. If additional
PAN is applied to the ryegrass in April -May, the PAN rate for the bermuda must be reduced by a
-----------------------------------------------------•- ---------------------
491261 Database Version 1.0( Date Printed: 08-09-2001 Crop Note Page 1

corresponding amount. This is necessary because ryegrass growth during April -May will reduce
bermuda yields and shorten the -time Bermuda can fully utilize the N. A harvest is required by heading or
April 7, which ever comes first to prevent shading of emerging bermuda during April -May period. To
favor the production of the bennuda, additional harvests of ryegrass will be required when the ryegrass
canopy reaches 12 to 15 inches height. The PAN rate for grazed systems with bermuda overseeded with
annual ryegrass must be reduced by 25%.
-------------------------------•----------------------------- ----
491261 Database Version 1.0( Date Printed: 08-09-200I Crop Note Page 2

Nutrient Management Plan For Animal Waste Utilization
08-09-2001
This plan has been prepared for:
Spell Hog Farm
Derwood K. Spell
2420 Five Bridge Road
Clinton, NC 28328
[phone]
This plan has been developed by:
Jeffery Brown
DSWC-FRO
225 Green Street
Suite 714 -
Fayetteville, NC 28301
[phone]
Type of Plan: Nitrogen Only with Manure Only
Owner/Manager/Producer Agreement
I (we) understand and agree to the specifications and the operation and maintenance
procedures established in this nutrient management plan which includes an animal waste
utilization plan for the farm named above. I have read and understand the Required
Specifications concerning animal waste management that are included with this plan.
tA 4-W g-31 d1
Signature (owner) Date
Signature (manager or producer) Date
This plan meets the minimum standards and specifications of the U.S. Department of
Agriculture - Natural Resources Conservation Service or the standard of practices
adopted by the Soil and Water Conservation Commission.
Plan Approved By: z"� ?— r ��
Te ica S-pe4ariist Signature Date
-----------------------•--------------------------------------------------------------
�491261 Database Version 1,06 Date Printed: 08-09-2001 Cover Page 1

Nutrients applied in accordance with this plan will be supplied from the
following source(s):
Commercial Fertilizer is not included in this plan.
S7
Swine Feeder -Finish Lagoon Liquid waste generated 1,149,480 als/ ear
by a 1,240 animal Swine Finishing Lagoon Liquid operation. This
production facility has waste storage ca acities of M2roximately 180 days.
Estimated Pounds of Plant Available Nitrogen Generated per Year
Broadcast
2649
Incorporated
4550
Injected
5010
Irrigated
2879
Actual PAN Applied
Year 1
2902
Notes:
In source ID, S means standard source, U means user defined source.
-------------------------------------------------------------------------- ------
491261 Database Version 1.06 Date Printed: 08-09-2001 Source Page 1

Narrative
This plan was written for the maximum of 75 lbs. PAN for small grain for winter grazing. The coastal
will be harvested for hay during the summer months, and the small grain overseed will be grazed during
the winter. It is important to note the application windows with this cropping system. The last day to
apply to the berrnuda is 8-31. The small grain should be applied to in split applications. The first
application to occur between September 15th - October 30th and the second one to occur between
February - March. The small grain should be harvested no later than April 7th. This should not be a
problem since the small grain overseed will be grazed. No application of waste should take place in the
months of November, December, and January.
---------------- --------------------------------------------------------
Preview Database Vernon 1 A Date Printed: 08-09-2001 Narrative Page 1

The Waste Utilization table shown below summarizes the waste utilization plan for this operation. This plan provides an estimate of the number of acres of '
cropland needed to use the nutrients being produced. The plan requires consideration of the realistic yields of the crops to be grown, their nutrient requirements,
and proper timing of applications to maximize nutrient uptake.
This table provides an estimate of the amount of nitrogen required by the crop being; grown and an estimate of the nitrogen amount being supplied by manure or
other by-products, commercial fertilizer and residual from previous crops. An estimate of the quantity of solid and liquid waste that will be applied on each field
in order to supply the indicated quantity of nitrogen from each source is also included.
A balance of the total manure produced and the total manure applied is included in the table to ensure that the plan adequately provides for the utilization of the
manure generated by the operation. Animal operations that generate liquid waste and utilize waste storage facilities (lagoons or holding ponds) may apply more or
less waste in any given year than is annually generated by the facility. In order to determine whether the plan adequately utilizes the waste produced by the
facility, the storage capacity table included in this plan should be reviewed to ensure that the design capacity of the storage facility is not exceeded during the
planning period.
Depending on the requirements of the crop and the nutrient content of the waste, some nutrients will likely be over or under applied if animal waste is being
utilized. Waste should be analyzed before each application cycle and annual soil tests are required if animal waste is being applied. Soil tests should be. used to
balance the nutrient application amounts with the realistic yields of the crop to be grown. Nutrient management plans may require that the application of animal
waste be limited so as to prevent over application of phosphorous when excessive levels of this nutrient are detected in a field.
Waste Utilization Table Year 1
Nitrogen
Comm.
ties.
Manure
Liquid
Solid
Liquid
Solid
PA
Fert.
(lbs/A)
PA
Manure
Manure
Manure
Manure
Nutrient
Nutrient
Nutrient
Applied
Applied
Applied
Applied
Peq'd
Applied
Applied
(acre)
(acre)
(Field)
(Field)
Source
'Total
Use.
RYI:
Applic.
Applic.
1000
'tract
I Field
I.D.
Soil Series
Acre
Acres
I Crop
RYE
Unit
I Period
N
N
I N°
Method
I Ibs/A
al/A
I tons
l0(10 R21S
tons
9846
1,2
S7
Wa ram
9.3
8.3
1 Cereal/Annual Rye
1.5
"tons
•9115-3/31
75
0
0
It -rig. .
75
29.9
0.0
248.2
0.0
OlS, Graze, 417
Ilarvest
----------------------------------------------- ------------------------------- .....-------------------------------- ---------------------
491261 Database Version 1.06 Date Printed; 08-09-2001 WUT Page l

Waste Utilization Table
Year l
Tract
I Field
Source
1.D.
soil Series
Total
Acre
Use.
lAcres,
Crop
RYE;
RYE-
Unit
Applic.
I Period
Nitmgen
PA
Nutrient
Req'd
Comm.
Fert.
Nutrient
Applied
Res.
(lbs/A)
N
Applic.
I Method
Manure
PA
Nutrient
Applied
Liquid
Manure
Applied
(acre)
Solid
Manure
Applied
(acre)
Liquid
Manure
Applied
(Field)
Solid
Manure
Applied
(Field)
N
N
Ibs1A
1000
I gal/A
tons
1006 gals
tons
9846
1 1 2
S7
I Wa ram
1 8.31
8.3
113etniudagrass flay
1 5.5
1 'funs
1 •311-8131
1 2751
01
0
1 Irrig.
1 2751
109.81
0.0
910.1
0.0
Lagoon Liquids
Total Applied, 1000 gallons
1,158
Total Produced, 1000 gallons
1,149
Bulance 1000 gallons
•9
Manure Solids
Total Applied, tons
0
Total Produced, tons
0
Balance tons
0
Notes: I. In the tract column, symbol •- means leased, otherwise, owned. 2. Symbol • means user entered data.
----------------------------------------------------------------- --------------------- -------------- --------------------------------
4912G1 Database Version 1.06 Date Printed: 08-09-2001 WUT Page 2

The Irrigation Application Factors for each field in this plan are shown in the following table.
Infiltration rate varies with soils. If applying waste nutrients through an irrigation system, you must
apply at a rate that will not result in runoff. This table provides the maximum application rate per hour
that may be applied to each field selected to receive wastewater. It also lists the maximum application
amount that each field may receive in any one application event.
Irrigation Application Factors
Tract
Field
Soil Series
Application Rate
incheslhour)
Application Amount
(inches)
9846
1,2
wagrarn
0.60
0.72
------------------•-----------•-------------------------------•- - - - - - - - -
491261 Database Version 1.06 Date Printed: 08-09-2001 IAF Page 1

The following Lagoon Sludge Nitrogen Utilization table provides an estimate of the number of acres needed for
sludge utilization for the indicated accumulation period. These estimates are based on average nitrogen
concentrations for each source, the number of animals in the facility and the plant available nitrogen application
rates shown in the second column.
Lagoon sludge contains nutrients and organic matter remaining after treatment and application of the effluent. At
clean out, this material must be utilized for crop production and applied at agronomic rates. In most cases, the
priority nutrient is nitrogen but other nutrients including phosphorous, copper and zinc can also be limiting. Since
nutrient levels are generally very high, application of sludge must be carefully applied.
Sites must first be evaluated for their suitability for sludge application. Ideally, effluent spray fields should not be
used for sludge application. If this is not possible, care should be taken not to load effluent application fields with
high amounts of copper and zinc so that additional effluent cannot be applied. On sites vulnerable to surface water
moving to streams and lakes, phosphorous is a concern. Soils containing very high phosphorous levels may also be
a concern.
Lagoon Sludge Nitrogen Utilization Table
Crop
Maximum
PA-N Rate
lb/ac
Maximum Sludge
Application Rate
1000 gal/ac
Minimum Acres
5 Years Accumulation
Minimum Acres
1 10 Years Accumulation
Minimum Acres
15 Years Accumulation
Swine Feeder -Finish Lagoon Sludge - Standard
Com 120 bu
150
13.16
15-551
31.09
46.64
Hay 6 ton K.Y.E.
3001
26.321
7.771
15.551
23.32
Soybean 40 bu
1601
14.04
14.571
29.151
43.72
------------------------------------------------------------------------g---g----------
491261 Database Version 1-06 Date Printed: 08-09-2001 Sludge Page 1

The Available Waste Storage Capacity table provides an estimate of the number of days of storage
capacity available at the end of each month of the plan. Available storage capacity is calculated as the
design storage capacity in days minus the number of days of net storage volume accumulated. The start
date is a value entered by the user and is defined as the date prior to applying nutrients to the first crop in
the plan at which storage volume in the lagoon or holding pond is equal to zero.
Available storage capacity should be greater than or equal to zero and less than or equal to the design
storage capacity of the facility. If the available storage capacity is greater than the design storage
capacity, this indicates that the plan calls for the application of nutrients that have not yet accumulated.
If available storage capacity is negative, the estimated volume of accumulated waste exceeds the design
storage volume of the structure. Either of these situations indicates that the planned application interval
in the waste utilization plan is inconsistent with the structure's temporary storage capacity.
Available Waste Storage Capacity
Source [Name
Swine Feeder -Finish Lagoon Liquid
Design Storage Capacity (Days)
Start Date
1 8/31
180
Plan Year
Month
Available Storage Capacity (Days)
1
1
66
1
2
58
1
3
61
1
4
60
1
5
87
1
6
129
1
7
170
1
8
180
1
9
170
1
10
159
1
11
129
1
12
98
* Available Storage Capacity is calculated as of the end of each month.
----------- ----- - ----------------
491261 Database Version 1.06 Date Printed: 08-09-2001 Capacity Page 1

Required Specifications For Animal Waste Management
1. Animal waste shall not reach surface waters of the state by runoff, drift,
manmade conveyances, direct application, or direct discharge during
operation or land application. Any discharge of waste that reaches
surface water is prohibited.
2. There must be documentation in the design fold that the producer either
owns or has an agreement for use of adequate land on which to properly
apply the waste. If the producer does not own adequate land to properly
dispose of the waste, he/she shall provide evidence of an agreement with a
landowner, who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner
of the waste production facility to secure an update of the Nutrient
Management Plan when there is a change in the operation, increase in
the number of animals, method of application, receiving crop type, or
available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs
for realistic crop yields based upon soil type, available moisture,
historical data, climatic conditions, and level of management; unless
there are regulations that restrict the rate of applications for other
nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre
per year. Waste may be applied to land eroding at more than 5 tons per
acre per year but less than 10 tons per acre per year provided grass filter
strips are installed where runoff leaves the field (see USDA, NRCS Field
Office Technical Guide Standard 393 - Filter Strips).
5. Odors can be reduced by injecting the waste or by disking after waste
application. Waste should not be applied when there is danger of drift
from the land application field.
6. When animal waste is to be applied on acres subject to flooding, waste
will be soil incorporated on conventionally tilled cropland. When waste is
applied to conservation tilled crops or grassland, the waste may be
broadcast provided the application does not occur during a season prone
to flooding (see "Weather and Climate in North Carolina" for guidance).
---------------------------- -------------------------------------------
491261 Database Version 1.06 Date Printed: 08-09-2001 Specification Page I

7. Liquid waste shall be applied at rates not to exceed the soil infiltration
rate such that runoff does not occur offsite or to surface waters and in a
method which does not cause drift from the site during application. No
ponding should occur in order to control odor and flies.
8. Animal waste shall not be applied to saturated soils, during rainfall
events, or when the soil surface is frozen.
9. Animal waste shall be applied on actively growing -crops in such a
manner that the crop is not covered with waste to a depth that would
inhibit growth. The potential for salt damage from animal waste should
also be considered.
10. Nutrients from waste shall not be applied in fall or winter for spring
planted crops on soils with a high potential for leaching. Waste/nutrient
loading rates on these soils should be held to a minimum and a suitable
winter cover crop planted to take up released nutrients. Waste shall not
be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11. Any new swine facility sited on or after October 11,1995 shall comply
with the following: The outer perimeter of the land area onto which
waste is applied from a lagoon that is a component of a swine farm shall
be at least 50 feet from any residential property boundary and canal.
Animal waste, other than swine waste from facilities sited on or after
October 1, 1995, shall not be applied closer that 25 feet to perennial
waters.
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other
than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and
public right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways,
or wetlands by a discharge or by over -spraying. Animal waste may be
applied to prior converted cropland provided the fields have been
approved as a land application site by a "technical specialist". Animal
waste shall not be applied on grassed waterways that discharge directly
------------- -------------- ---------------------
491261 Database Version 1,06 Date Printed: 08-09-2001 Specification Page 2

into water courses, and on other grassed waterways, waste shall be
applied ar agronomic rates in a manner that causes not runoff or drift
from site.
16. Domestic and industrial waste from washdown facilities, showers, toilets,
sinks, etc., shall not be discharged into the animal waste management
system.
17. A protective cover of appropriate vegetation will be established on all
disturbed areas (lagoon embankments, berms, pipe runs, etc.). Areas
shall be fenced, as necessary, to protect the vegetation. Vegetation such
as trees, shrubs, and other woody species, etc., are limited to areas where
considered appropriate. Lagoon areas should be kept mowed and
accessible. Berms and structures should be inspected regularly for
evidence of erosion, leakage, or discharge.
18. If animal production at the facility is to be suspended or terminated, the
owner is responsible for obtaining and implementing a "closure plan"
which will eliminate the possibility of an illegal discharge, pollution, and
erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected
on a regular basis to prevent breakdowns, leaks, and spills. A regular
maintenance checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other
crops for direct human consumption. However, if animal waste is used
on crops for direct human consumption, it should only be applied
pre -plant with no further applications of animal waste during the crop
season.
21. Highly visible markers shall be installed to mark the top and bottom
elevations of the temporary storage (pumping volume) of all waste
treatment lagoons. Pumping shall be managed to maintain the liquid
level between the markers. A marker will be required to mark the
maximum storage volume for waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested
at least annually at crop sites where waste products are applied.
---------------------------- ----------------- ----------------- -------------------------
491261 Database Version 1.06 Date Printed: 08-09-2001 Specification Page 3

Nitrogen shall be the rate -determining nutrient, unless other restrictions
require waste to be applied based on other nutrients, resulting in a lower
application rate than a nitrogen based rate. Zinc and copper levels in the
soils shall be monitored and alternative crop sites shall be used when
these metals approach excessive levels. pH shall be adjusted and
maintained for optimum crop production. Soil and waste analysis
records shall be kept for a minimum of five years. Poultry dry waste
application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a
minimum of five years.
23. Dead animals will be disposed of in a manner that meets North Carolina
regulations.
------------------------------------------------ ---- --------------
491261 Database Version 1.06 Date Printed: 08-09-2001 Specification Page 4

Crop Notes
The following crop note applies to field(s): 1,2
Bermudagrass Coastal Plain, Mineral Soil, Moderately Well Drained.
Adaptation: Well -adapted.
In the Coastal Plain, hybrid bermudagrass sprigs can be planted Mar. 1 to Mar. 31. Cover sprigs I" to 3"
deep (1.5" optimal). Sprigs should be planted quickly after digging and not allowed to dry in sun and
wind. For Coastal and Tifton 78 plant at least 10 bu/ac in 3' rows, spaced 2' to 3' in the row. Generally a
rate of 30 bu/ac is satisfactory to produce full groundcover in one or two years under good growing
conditions. Tifton 44 spreads slowly, so use at least 40 bu/ac in 1.5' to 2' rows spaced V to 1.5' in row.
For broadcast/disked-in sprigs use about 60 bu/ac. Soil test for the'amounts of lime, phosphorus,
potassium and micronutrients to apply preplant and for annual maintenance. Apply 60 to 100 lb/ac N in
the establishment year in split applications in April and July. For established stands apply 180 to 240
lb/ac N annually in split applications, usually in April and following the first and second hay cuts.
Reduce N rates by 25% for grazing. Refer to NCSU Technical Bulletin 305 Production and Utilization
of Pastures and Forages in North Carolina for more information or consult your regional agronomist or
extension agent for assistance.
The following crop note applies to field(s): 1,2
Cereal/Annual Rye Overseeded -- Grazed
CEREAL RYE
The cereal rye should be planted by October 15 to provide the best opportunity to get winter growth. The
most consistent stands are obtained from drilling rye into short (less than 3 inches tall) bermudagrass sod.
If drilling is not possible, the seeds may be broadcast on short bermuda sod followed by a light
cultivation with a disc or tillage implement. The seeding rate for broadcast planting of seeds should be
1.5 times the rate for drilled seeds- The last application of animal waste is to be applied to the bcrmuda
prior to August 31. An application of 50 lbs/acre of Plant Available N (PAN) may be applied between
September 15 and October 30. An additional 501bs.acre of PAN may be applied in February -March. If
rye growth is harvested on time and does not significantly shade the bermuda, PAN rates for the
subsequent bermuda crop are based on realistic yields of berrnuda. A harvest is required prior to heading
or April 7, which ever comes first. This is necessary to minimize the potential for shading bermuda and
reducing its yields. The PAN rate for grazed systems with bermuda overseeded with cereal rye must be
reduced by 25%.
ANNUAL RYEGRASS
Annual ryegrass should be planted by October 15 to provide the best opportunity to get winter growth.
The most consistent stands are obtained from drilling ryegrass into short (less than 3 inches tall)
bermudagrass sod. If drilling is not possible, the seeds may be broadcast on short bermuda sod followed
by a light cultivation with a disc or tillage implement. The seeding rate for broadcast planting of seeds
should be 1.5 times the rate for drilled seeds. The last application of animal waste is to be applied to the
Bermuda prior to August 31. An application of 50 lbs/acre of PAN may be applied between September
15 and October 30. An additional 50 lbs. acre of PAN may be applied in February -March. If additional
PAN is applied to the ryegrass in April -May, the PAN rate for the bermuda must be reduced by a
---------------------------- •---- - - - - -- ------•--------------------------
491261 Database Version 1.0f Date Printed: 08-09-2001 Crop Note Page I

corresponding amount. This is necessary because ryegrass growth during April -May will reduce
bertnuda yields and shorted the -time bermuda can fully utilize the N. A harvest is required by heading or
April 7, which ever comes first to prevent shading of emerging bermuda during April -May period. To
favor the production of the bermuda, additional harvests of ryegrass will be required when the ryegrass
canopy reaches 12 to 15 inches height. The PAN rate for grazed systems with bermuda overseeded with
annual ryegrass must be reduced by 25%.
------------------------------------------------------------------- -----------------
491261 Database Version 1.0( Date Printed: 08-09-2001 Crop Note Page 2

'1x phi + A 1 1k .r fir �•F ,t
3�. a+ ^. rf�.'�',��:•'1r �'r ,� r iiyl. +"��.�, b;
11, T T x xs u�;;[�„ -•/+' 1 s„f ,[� f 1 aq,•k�� dy+'P7� }'tF�ii� A777+v,•yM y.r�iR:' C.:. iG;+rr:Jh' _-.
1.rt 15 F '.i :!''� •y, J'' �t,,iiyi f..r '�F Ix'j Ir tt n't,�t "PPGG"SS a� +
11 't 4 4r.21 t1 rF 4�, SrR kr ttl�v i y-Y•} • r.j `. •V�
7 s.'arr ?Jf .I i lq•r 1� ra i"` f F I �'.,J�`; tt,f� r 1: 1;h Kr,vAY^ ,r1''e ; i! I S:J ffLiti l� a ,. y r sU• f1 F1, ='+'F 1•
:. r + i i� ��i"•Ra•,:>'P'..� t f•`i.�f'r :f1t� x���i }.�,'frS�r�`Ip?�}�i t `7�" J���;f�lat.�:ii1;J J� r+ �•t""� -''1'•'
I •''' t � y '�' - r, ti (- t 4y},p ft{ � 1 k r �y .t�S- r�b . ,y. ,> k'f•4 l�� �'� i .':+ •
' �' - ` � 1• '� 1 :m 1ft{! �� 1 ; I't)t,'i� itiYt Ir��i rsf't �}f I!, tri.t"c
_ii k k..Js't r i
.11tK'i.�,, iyy�, 1.i I: 1tL[ffr ^• Y `i ..y�(Sw
' I F .ir ! ? s�} rr �ELh t r`4 r•4• riF IcT,} n 1}i�h. -', `�S y�.,
:`iF tll.` .i.. it n } .+t•}, �.y.K�Q J rL �" 7 frba=1: *j'nt,{I 'i'ij 1yf�a�aiert+71a9
Ye 4 k i ys �4 ♦ Nli i t 'TY 1 fa 1' M d
[.� y �,♦l. �. r a r^ ' •�+i A
-'1 i' t "- •R' .s-+'7 , r �� I r�j� i
5 .r ���rs�'1''..}.. 5S , (lam i"#rJ.'!r� � r• r nn fr+arar,�F.+ t+x�y s,r4i r,�y] L•1 �:} 7axL.,� IryY+ty i�l T• !!: � •
. } �+` rl S ° i ry r.l..t.e'Ik�- ;5s,o.G°�y �'r�'%.isdu�t�j'l'{�r �rn !{�. N-.: r.!eW,'.'�I'J7RRPt177tPP �:l ai�•�i{'rr ��y� d1�•S �a�f r ��
r r3.en+,, S,, •' !C M. er N .Iw�•lyytl iE.f ��? 1-!-a�'i ., '.:'�!{,tF 1- ... � y' - �r '�• � 1.. ` � u.,
,� - •.t.. ..• tlr s i - Lr•vcr+F.'« Y .q... Yr - u ., "�k.i:rs,...' k t +� •.I4i .vt '1 st ;'_F i.:,. ;�,••o +F.rn.� r ,,,.., .".. � Kkis-ab I + ! i h; • '
.ne 4. •* rta V� yl- ;fir w•'sa.trr.:sy3 I'eJ•st+ji4 i•w:.nr'vL1.5' �Y „a Ytj•1.1 } .tH,,r.;r �:¢R :Sr•_:'I'9: t.1'.,p rt"''�-r 1, 1 r-r'; y`
•,� }-r � ! 17; v �iyr iFyJt� r,... ,.srr�. .r '{' .iL. a. t y,.tr r, 1,ry•.s:,w ,x fe�n'ir' r .�.Is hp' � �•P �� . . -, _
' �.i ;rrr7 r-- 1 1• 1r.:�S'.: r•r ,•+ ,y, •'t t r.s.r ., sy + [, A; rr l
r r 4R„ �: .'4., � i.- 1... �ts''• �•r{�� •ry, i t ,e.< ,�• u• � , ' ti �,r--_ - - -- ;1f
I r, s. i,:,r:Y Y.�,-+g.vr.-Jn�iFrnr,. ',>t5 p: r r .• �., .r sd u,�Ji iv,' � � e 6 ,. e� 1. ri1'TS+^'f I .14-+:... -
�' , ,. S � yt. ..{•.. . e•,•.!�^nib• '' 'i `°� ,.¢'� '� ��i[F�'F t4:r��+•Mii
. •i"��k• .y- "t'tc..'i, ;;�wcr",^(. �,14 r•.1. •.1 r; ,i ty.•r+,yt r I,. l,: n,?s-,i �,�`.`�h�y'� ;1°,t�i t�tt ..y.t1 c�p-.r�4 •1rr:r•;e4.. .�. s+.:.'w.k.�
.r 'rr'rr�.rr' 1,•.�•,- .-p,,, r •.:,e. J r!'!r ri''7 - ,t"k,;"l, .'�'rrrS ma F^k Y" '�`�. =.■ 41 4..�. rc�.i - r. •d •"
y ..•� ��r ,�� .1.,`• •tii,'s'r lt,V! 1' 1 4�, i' h) r, .� r,..,
'�, :� 'r s.`_' y.. �r t�.v. J.ita .rl„w-� r . Ley ^•r •t. Ir•a:' -din .:'r, � � •,r`•Iri'X� i :r !] . ...�s --[,
-'� s x Y � s +. � f. •�• '•;t. 1 �'I ��! ,t:=fit' � rfl� y -�•" x r,'} i �+`t,ty . ..t.f � 1
JAR
ii;r ` - :`e; • ferry F �s [ �.t . tl t 1 ' i. a• �i ;5,' i�ir { +� t ? : +� s h ��
Wt�' � s r,y( ,F+� -� •i ... �". �f �,I ! �r5 S t � i s I .yin
' . � r' � .<! »s` 'f, '. 4iK71� '� 'Siy]' r'.1 �, rv� � 5 � :.y=""::[S•i.""`-
r is +.(�h"Q7 ''••1 i.���. F ���!-;..,-`., s5`1,..' ;.
y r
s'. s r7 fir'(. f'. A... +• 't :��. '. F' +i4f :T y�'�,.,t-�� 1S� ' �i;• t,r' .
:a{$F } ` 1 •„} .•- ,i+ F ;'� :it-1 , � rk�t ,� •y1*� f +ha /r� rl r- SY r
�' i t ^tl�st E,z- R +�:. I( r, etr�•n•�.. '-'7, yNfi'p r.i � r r:'���� ��j• r' � [i,.� "•"s�l ill` 'f _ i s
F�. rlr a• '4t d [r�„r •� xtr sfi 01WY' '�` r ,. '.r�•r •� f" {. *7(,t CSs,)i- 't,-
'`x r r� :u•' ,. '•+,..}'y'fi i. '`.k ,.. ,. Y.� �r' r .kj.11 =a w *1'j , } `r 1 +<y
'aww' :1F i th r t c,• °.did iY
ti nyi • • � �`i'��'i� 1 � i�11•� r rti { 1`�'a �� �.' � y' r+. '
•�- GR�tl} � Itti� �1r `.' tb I ti . ° - � [ # + �,• . . ,
-� ? Y�•� tarnl,� 0� �. s s3 k�' .y. I , - 1 v f7J .j 1 Jr., � ' FJ ,',.
-'y�'4�
I
� �= ysl I �I4� y C.. ��. �+tt ! a> }r+ '�• }sr�t�aly^1'; 1 ?< f'o`; ' y'. yf�J : y4 t F � 'y'. J t ')� •'r i. � �.e [ C
S r r•} Y R.tr .F.tJ �N'� f) s +�� "•1 '�' r• n Ir ��il, 3 `.• r } 7 ail s.
rh rsy� Cry ,%"'i.u-4 F•f }.V i ,p .a�rf,5 r �j7 /s k 1. �'1 + �
�;; �. v`' ^r ,�' r, :� r :.s � , i % • • � Pik'' I C -u •� p+ ;
'F , tr'1.: � r ygM1�, ,., r �. Jyrt y�i�a<' r. r 19�9�� i •i { .,�� ' {� .,� [ _I 4 + f � erl.r
JISgg �.1�'y", .y{wrt ;i T l .t Itiv"F'•;,. .,Si,,. I i'' s+:
obi nl", •��' rr 1 i-{#t�,� ,s 3 3�ry�. 1 1 �� j > r'if ! •TF`4iS�' } f�'�
i.t^ �, �,r«• i ��(( 7. ' y �'� • 'iK X s 4� 'j �t�t�d�'r ' ' �t, '3a'� � � .P }
•':,:o i• •?�, .rT,•j� � �, yiY.r' il'.•��- .a�� jar ,*i{ 1 f "�,�� � � r
rr^�y.'l"}r'S. qt 5_ •r r)K),� [[',• f�' 11� .F•�e'ii `f` y► ',r W'r ,
k• r rayati
•'•r�r �y eS ` f n f�Y"�F.�e,�',� .:S.r ii J?I;4�� ,f� �'�,a•F� tw. (":� t '•�i Yit� t i �p 9t@`z o- { ="A
y�st w�„� ,�.+sj4`Y: ►P 11 t �ti r�l i� aS.wq"�' S ' t'C;,1};d♦ ,�
cis r��„ �� ,, , s � .i: "i i . '•i• , � � b, �' [)�•ix I s r ,
;:{/ [y k�F'"ti a�i� r +' {'e'r+r�1,•�� tr1 I,ll
V J' r-I ii l' 1 ir��,, N Y ' , I .i•'l � � 7 � 9�� Br,. r-
YIS ref � s ! �{t;151tr� �`"`��,s � � � , i�t + I��� ti�ti- , as ?y•✓r i I
In ���� �'{o( 11 _ f C"far +c� 'c'r�r'�p�` _� i !• r 4•r,r„ r,��.� r`i,k' r: r 1 - �i� ��. " 1 j c)�� � � ;�tl r' � !h
IY dLrs.,•i I� r x t r9'', t v� S, �A , d.:e3 �Ff777F}!I1'i��. r6i �t¢!'I - kv'rti r P.I r � .,g. r, I I ' r t J' k }'r y !3, is
�34 J 1-'^ ' t � •� y � F h k Ik' i� -: 11 I' w.• i ,{ i]'t
ir�i k' r[ �',<� i li 411�1 [ ,� i r•' C ri1+ " s.,l n. � 'F.+ -[E�_ :" / ':,+�
,. I 1"�^ tI't�,r ��F,� t s ,�ri' }" � yr� 1x� l• �" i t �',. �
t L {�s(� �.t-�I�r• .i, 1
,ii J i s i)�.'.; +'P�I ,{ % : �I �i44'rr r+ ,p. ir��` t i9S�M *1}., N1.��CM:.�sF„ni,.�,dn•.,,,,,q,..... � ,,. «. �'{� �
_ +r� { 4,s ,1 K N�iy; rtY l�ry +,{ ��b(v�� � +raSJ jt � l + ;-�'it"xw:,'.,^�`'y`..•.� l
�. •�a %% r' - Vy,�n r -_ �i,u I' } � � S ry 3 r6 ^Is a � - � - v r F tb7 a �
/. r;�,�+aSl,i rtr.;.r r r �"?Fls'���'� �' � yi�ryi ,;, a+w�l �'Y'L'L l e 1a '�ti�r c+ �'t�rJC.wi!•{ }�,
e Y, 1, ". •. a �. d['Y;S a '` f ' �v� r 2fi -�, �I, { .� �.�A N{[13 2 Si�f t+ '
hrr ' � •- �.5�t>al�rl.� ! k ' ',t•. '''�• '''r '.'�',:. sq r � Yv„ - r I., r 1 . �S �? rFil' r i �A"xi5�t ♦y;'.: 'f si ' ���''•4 �r li �d,�`� . . wi
N"
i.
x•, rr tr, � � .� �+{-�ri IF: IS cfi�t P;•,9 ffrl f"blt:r s i n�a'nri I a,Jy r+l}; i r +.,r i r l ! �C� ^FlQ'. 'Y; �i l lii 4 '..�r, �,
• [ ! �i Y' 4.' n. �j ' e. p i Ir. y !}M1�!. k5 � Ir 1 'I `I 1� .I bf9T. :r"
r +fir ''-e f,F'� kl e ,'t: 5{.FI r�ire ' y a f �i }l a $�[ ✓rk 1'•ut�r^ dot M 1,. "C!`,.plr r••: f ¢ :y'� r �..4
1 I'. k'i ,a.. :�`?,,`„'r;-l��"•ilt�n�;, i e(.a'�'eti+r.�iw'rc',� .+1.xrit,.+lY,n.:YZsa•',M"1LixJnl::�4"�rl4+�r'f"�h4��'�lxasak'�:� .;rrSl,�t�ft as a.,

�S
Wettable Acres Determination Certification
Name of Facility: F_, - Facility Number: V
Owner(s) Name: Phone No: 0/
3
Mailing Address: ,;?��G rivcf— ^izl� P e/•n+� /y a y
By signing this form, the facility ownerand Technical Specialist acknowledge the completion ofthe
Wettable Acres Determination. All necessary Wettable Acre Determination Field Data Sheets and
calculations were completed to conduct a Wettable Acre Determination, The facility's Waste
Utilization Plan has been amended as necessary to reflect actual wetted acreage. A copy of all
worksheets, calculations, and other Wettable Acres Determination documents; along with the
applicable Waste Utilization Plan and Wettable Acre Determination Certification will be flied with
the local Soil and Water Conservation District. A copy will also be kept on site with the Certified
Animal Waste Management Plan. Any future modifications must be approved by a technical
specialist and filed with the Soil and Water Conservation District prior to implementation_ If any
modifications to the existing irrigation system or any new irrigation equipment was required to
adequately address the waste management needs of this facility, an Irrigation Specialist or
Professional Engineer has certified the design and installation below.
Owner Name:)
Owner Signature:�f ..i _JUG Date: 3 -Q
Technical Specialist Name:T-G
Technical Specialist Signature:
If assisted by an irrigation Specialist or Professional Engineer please read and sign below:
Animal waste application equipment has been designed or modified to apply waste as necessary to
accommodate the waste management plan and according to NRCS Standards. Animal waste
application equipment has been installed according to MRCS Standards and is ready for use.
Irrigation Specialist/PE Name:
Irrigation Specialist/PE Signature: Date:
Submit this form to-
Attn. Sonya Avant
Non -Discharge Compliance Unit
Division of Water Quality
1617 Mail Service Center
Raleigh, NC 27699-1617
WADC — 7/99
f DE-`�
-FRO
`��LDwo

State of North Carolina
Department of Environment
and Natural Resources
Jaynes B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
D.K. Spell
Spell Hog Farm
2420 Five Bridge Road
Clinton NC 28328
Dear D.K. Spell:
0 •
mom --
NCDENR
NORTH CAROLINA DEPARTMENT OF -
ENVIRONMENT AND NATURAL RESOURCES
November 6, 2000
Ld
NOV 0 8 2000
t~, •„ FT I
LLE
PCG.
Subject: Notification for Wettable Acre Determination
Animal Waste Management System
Spell Hog Farm
Facility Number 92427
Sampson County
A letter dated January 15, 1999 was sent to advise you about concerns associated with Certified Animal
Waste Management Plans and the method by which the irrigated acres within the plans were calculated. Only
the acres that are wetted can be credited in the waste management plan as receiving waste application. Any
acreage within the plan that can not be reached by waste application equipment can not be used as part of your
plan.
An evaluation by Audrey Oxendine on 6/24/99 was made to review the actual number of acres at your
facility that receive animal waste during land application. The evaluation of your facility has yielded one of
the following two results as indicated by the box marked with an "X".
Category 1:
The evaluation of your facility could not be completed due to a lack of information. Please
contact your Technical Specialist to assist in providing Trent Allen the necessary
information to potentially exempt your facility from undergoing a complete wettable acre
determination. Please submit this information to Trent Allen, at 225 Green Street, Suite
714, Fayetteville, NC 28301, within in 90 days of the receipt of this letter. If you have any
questions please contact Trent Allen at [phone]. If within 90 days you are unable
to provide Trent Allen with the information you are automatically required to complete
a Wettable Acre Determination as described by Category 2 below, within 180 days
of receipt of this letter.
1617 Mail Senice Center, Raleigh. North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

Notification for Wettable Acre Detennination
Animal Waste Management System
Page 2
Category 2:
❑ Your facility has been identified by the Department of Environment and Natural Resources
as a facility that may have overestimated the number of acres actually receiving animal
waste. Therefore, some or all of your fields may be exceeding the allowable loading rates
set in your Certified Animal Waste Management Plan.
In order to resolve this issue, please contact a designated Technical Specialist to have him
or her conduct a Wettable Acre Determination for your facility. The Technical Specialist must
be one that has been approved by the Soil and Water Conservation Commission to conduct
Wettable Acre Determinations. Many Technical Specialist with the N.C. Cooperative Extension
Service, the Soil and Water Conservation Districts, the Natural Resources Conservation
Service, and the Division of Soil and Water Conservation have received this special
designation, You may also contact a private Technical Specialist who has received this
designation, or a Professional Engineer.
All needed modifications to your Animal Waste Management System must be made and
the Wettable Acres Determination Certification must be returned to DWO within the next
180 days. If the needed modifications are not made and if the form is not returned within the
required time, DWQ will be forced to take appropriate enforcement actions to bring this facility
into compliance. These actions may include civil penalty assessments, permit revocation,
and/or injunctive relief.
Once a Wettable Acre Determination has been completed, a copy of the attached Wettable
Acre Determination Certification must be submitted to the address listed on the form. Please
note that both the owner and the Technical Specialist must sign the certification. A copy of all
the Wettable Acre Determination documentation that applies to your Waste Utilization Plan
must be kept at your facility. DWQ and the Division of Soil & Water Conservation Staff will
review all documentation during their annual visit of your facility. An additional copy must by
kept on file at the local Soil & Water Conservation District Office. Please note that if you install
or modify your irrigation system, a designated Irrigation Specialist or a Professional Engineer
must also sign the Wettable Acre Determination Certification.
.. Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Sonya Avant of our
Central Office staff at [phone] ext. 571.
Sincerely,
Kerr T. Stevens
cc: Fayetteville Regional Office
Sampson County Soil and Water Conservation District
Facility File
Dorrwood Farms

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
D.K. Spell
Spell Ho; Farm
2420 Five Bridge Road
Clinton NC 28328
Dear Derwood K. Spell:
•.
ECE" !'
NOV 0 8 200#qCDENR
Fn�`- I tOLL NORTH CAROLINA DEPARTMENT OF
REG. OFFICL NVIRONMENT ANo NATURAL RESOURCES
November 6, 2000
Subject: Certificate of Coverage No. AWS820427
Spell Hog Farm
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
In accordance with your application received on December 20, 1999, we are forwarding this Certificate
of Coverage (COC) issued to D.K. Spell, authorizing the operation of the subject animal waste
collection, treatment, storage and Iand application system in accordance with General Permit
AWG100000. This approval shall consist of the operation of this system including, but not limited to,
the management of animal waste from the Spell Hog Farm, located in Sampson County, with an animal
capacity of no greater than 1240 Feeder to Finish and the application to land as specified in the Certified
Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. Please pay particular attention to Condition II.10 with respect to vegetation on
lagoon embankment and to Condition II1.2 with respect to a required waste -level gauge. An
adequate system for collecting and maintaining the required monitoring data and operational information
must be established for this farm. Any increase in waste production greater than the certified design
capacity or increase in number of stocked animals above the number authorized by this COC will require
a modification to the CAWMP and this COC and shall be completed prior to actual increase in either
wastewater flow or number of animals.
The facility's CAWMP meets all requirements in place at the time of certification. However, it appears
that the irrigation system on site may not adequately cover all acreage listed in the Waste Utilization Plan.
The owner should begin to address this inconsistency as soon as possible.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215,6A through 143-216.6C including civil penalties, criminal penalties, and injunctive relief.
1617 Mail Service Center, Aalei­h, North Carolina 27699-1617 Telephone [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/]0% post -consumer paper

Certificate of Coverage AWS820427
Spell Hog Farm
Page 2
This COC is not automatically transferable. A name/ownership change application must be submitted to
the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual non -discharge permit by contacting the engineer listed below for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
The subject farm is located in the Fayetteville Regional Office. The Regional Office Water Quality Staff
may be reached at [phone]. If you need additional information concerning this COC or the
General Permit, please contact' Sue Homewood at [phone] ext. 502.
Since I ,
r
-------------
Kerr T. Stevens
cc: (Certificate of Coverage only for all cc's)
Sampson County Health Department
Fayetteville Regional Office, Water Quality Section
Sampson County Soil and Water Conservation District
Permit File
NDPU Files

State of North Carolina '� R Uc4! Vl
Department of Environment and Natural Resources,,
Division of Water uality e2 oN
Non -Discharge Permit Application Form �a�a , ��9J)
(THIS FORM MAY BE PHOTOCOPIED FOR USE AS AN ORIGINAL.) 71�0f09
General Permit - Existing Animal Waste Operations*V
The following questions have been completed utilizing informations on file with the Division. Please
review the information for completeness and make any corrections that are appropriate. If a
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
1. GENERAL INFORMATION:
I.I Facility Name: ill H2g Farm _
1.2 Print Land Owner's name:
1.3 Mailing address: 2420 Five Bridge Road
City, State. Clinton NC Zip: 28328
Telephone Number (include area code): 910-564-4075
1.4 County where facility is located: Sampson
1.5 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a copy
of a county road map with the location of the farm identified): On the northeast side of SR_1326 amrox..4 miles southeast
of intersection with SR 1325, northeast of Salemburg,NC..
1.6 Print Farm Manager's name (if different from Land Owner):
t _7 Lessee's / Integrator's name (if applicable; please circle which type is listed): Lia,N+ 5 fn
1.8 Date Facility Originally Began Operation: 01/01/88
I.9 Date(s) of Facility Expansion(s) (if applicable):
2. OPERATION INFORMATION:
2.1 Facility No.: 82 (county number); 427 (facility number).
2.2 Operation Description: Swine operation
Feeder to Finish
1240- Certified Design Capacity
Is the above information correct? X yes; = no. If no, correct below using the design capacity of the facility
The "No. of Animals" should be the maximum number for which the waste management structures were designed.
TN of Swine No. of Animals Tvpe of Poultry No. of Animals TyW of Cattle No. of Animals
• Wean to Feeder - Layer • Dairy
• Feeder to Finish - Non -Layer - Beef
• Farrow to Wean (# sow) • Turkey
• Farrow I Feeder (I# sow)
• Farrow to Finish (# sow)
Other Type of Livestock on the farm: No. of Animals:
FORM: AWO-G-E 5/28/98
Page I of 4 82 - 427

3,
2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): _ 17.5 1 Required Acreage (as listed in the AWMP): 14.0
2.4 Number of lagoons/ storage ponds (circle which is applicable):
2.5 Are subsurface drains present within 100' of any of the application fields`? YES or NO please circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES orN5) (please circle one)
2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, dards, etc.) (Swine Only)
or NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited? /'� ��
What was the date that this facility's land application areas were sited?
REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item_
Applicants Initials
3. l One completed and signed original and one copy of the application for General Permit- Animal
Waste Operations;
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit application
for animal waste operations.
The CAWMP must include the following components. Some of these components may not
have been required at the time the facility was certified but should be added to the
CAWMP for permitting purposes:
3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application.
3.3.4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application Feld.
3.3.8 The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.3.10 A site schematic.
33.11 Emergency Action Plan.
3.3.12 Insect Control Checklist with chosen best management practices noted.
3.3.13 Odor Control Checklist with chosen best management practices noted.
3.3.14 Mortality Control Checklist with the selected method noted.
3.3,15 Lagoon/storage pond capacity documentation (design, calculations, etc.). Please be
we to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility.
3.3.16 Operation and Maintenance Plan.
If your CAWMP includes any components not shown on this list, please include the
additional components with your submittal.
FORM: AWO•G-E 5/28/98 Page 2 of 4 82 - 4n

Facility Number: 82 - 427
Facility Name: Spell Hog Farm
4. APPLICANT'S CERTIFICATION:
1, O,k. -e U -
wprERQU�ED
sEcnau
4020f9
Ako�10,48 pe
r (Land Owner's name listed in questions 1.2), attest that
this application fort' Sn-e ((_ f�� Fo'^7 _ (Facility name listed in question 1.1)
has been reviewed by me Ad is accurate andcomplete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if al] required supporting information and attachments are not included, this application package
will be retuimcdao me as mcqnplet I
Signature- Date
5. MANAGER'S CERTIFICATION: (complete only if different from the Land Owner)
1, (Mans„er's name listed in question 1.6), attest that this
application for (Facility name listed in question I.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be returned as incomplete.
Signature
Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
1617 MAIL SERVICE CENTER
RALEIGH, NORTH CAROLINA 27699-16I7
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
FORM: AWO-G-E 5128/98 Page 3 of 4 82 - 427

WASTE UTILIZATION PLAN
Dogwood Farms
Wednesday, October 14, 1998
Producer: D. K. spell
Farm Name : spell Hog Farts
2420 Five Bridge Rd.
Clinton,NC 28328
Telephone # : [phone]
Type of Operation : Feederto Finish swine
Number of Animals : 1240 hop design capacity
Application Method: Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface and/or groundwater. The plant nutrients in the animal waste should be
used to reduce the amount of commercial fertilizer required for the crops in the fields where
waste is to be applied. This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil tests are strongly
encouraged so that all plant nutrients can be balanced for realistic yields of the crop to be
grown.
Several factors are important in implementing your waste utilization plan in order to
maximize the fertilizer value of the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the needs of the crop to be
grown and the nutrient contents of the waste. Do not apply more nitrogen than the crop
can utilize. Soil types are important as they have different infiltration rates, leaching
potentials, cation exchange capacities, and avaialable water holding capacities. Normally
waste shall not be applied to land eroding at greater than 5 tons per acre per year. With
special pre -cautions, waste may be applied to land eroding at up to 10 tons per acre per
year. ❑o not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed under
DEM regulations. Wind conditions should also be considered to avoid drift and downwind
odor problems. To maximize the value of the nutrients for crop production and to reduce the
potential for pollution, the waste should be applied to a growing crop or applied to bare
ground not more than 30 days prior to planting. Injecting the waste or disking will conserve
nutrients and reduce odor problems. This plan is based on waste application through
irrigation for this is the manner in which you have chosen to apply your waste. if you choose
to inject the waste in the future, you need to revise this plan. Nutrient levels for injecting
waste and irrigating waste are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. Acreage requirements should be based on the waste analysis report
from your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for ananlysis. This waste
utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
21-1.0217 adopted by the Environmental Management Commission.
Page 1 of 9

AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
1240 hogs X 1.9 tons wastelhogslyear = 2356 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
1240 hogs X 2.3 Ibs PAN/hogs/year = 2852 PAN/year
Applying the above amount of waste is a big job. You should plan time and have
appropriate equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on the crop to be grown,
soil type and suface application.
TABLE 1 . ACRES OWNED BY PRODUCER
TRACT FIELD SOIL TYPE &CLASS- CROP YIELD LBS AW COMM ACRES LBS AW APPL IC.
DETERMINING PHASE COVE WACRE NACRE USED TIME
9846
1
WAG RAM 0-6%
BP
4.1
205
0
9
1845
MAR-OCT
W46
1
WAG RAM 0-6%
SG
1
75
0
9
675
-OCT: FEB-1V
9846
2
WAGRAM 0-6%
SP
4A
205
0
1.5
307.5
MAR-OCT
9846
2
WAGRAM 0-696
SG
1
75
0
1.5
112.5
SEP-MAY
TOTALS. 2940
- Indicates that this field is being overseeded (i.e. interplanted) or winter annuals follow
summer annuals.
" Indicates a Crop Rotation
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N
requirments. Beginning in 1996 the Coastal Zone Management Act will require farmers in
some eastern counties of NC to have a nutrient management plan that addresses all
nutrients. This plan only addresses Nitrogen.
Page 2 of 9

�, TABLE 2: ACRES WITH AGREEMENT OITLONG TERM LEAS
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land. See required specifications 2.)
There are no Acres Leased
Indicates that this field is being overseeded (i.e. interplanted) or winter annuals follow
summer annuals.
* Indicates a Crop Rotation
* Acreage figures may exceed total acreage in field due to overseeding.
**Lbs AW N (animal waste nitrogen) equals total required nitrogen less any commercial
nitrogen (COMM N) supplied.
The following legend explains the crop codes used in TABLES 1 and 2 above:
CROP CODE CROP UNITS LBS NIUNIT
BP
HYBRID BERMUDAGRASS-PASTURE
TONS
50
SG
SMALL GRAIN OVERSEEDED
AC
50
Page 3 of 9

TOTALS FROM TABLES 1 AND ' . `
ACRES LSS AW
N USED
TABLE 1 1 10.51 2,940
TOTALS: j 10.51 2.9401
AMOUNT OF N PRODUCED: 2,252
BALANCE -8
'** This number must be less than or equal to 0 in order to fully utilize the animal waste
N produced.
Acres show in each of the preceeding tables are considered to be the usable acres
excluding required buffers, filter Strips along ditches, odd areas unable to be irrigated, and
perimeter areas not receiving full application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than the acres shown in the
tables.
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of
sludge at agronomic rates. The sludge will be nurturient rich and will require precautionary
measures to prevent over application of nutrients or other elements. Your production facility
will produce approximately 458.8 pounds of plant available nitrogen (PAN) per year in the
sludge that will need to be removed on a periodic basis. This figure is PAN when
broadcasting the sludge. Please be aware that additional acres of land, as well special
equipment, may be needed when you remove this sludge.
See the attached map showing the fields to be used for the utilization of waste water
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the soil at the time of
irrigation such that runoff or ponding occurs. This rate is limited by initial soil moisture
content, soil structure, soil texture, water droplet size, and organic solids. The application
amount should not exceed the available water holding capacity of the soil at the time of
irrigation nor should the plant available nitrogen applied exceed the nitrogen needs of the
crop.
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every 5.92 months. In no instance should the volume
of waste being stored in your structure be within 1.7 feet of the top of the dike.
If surface irrigation is the method of land application for this plan, it is the responsiblity of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in Tables 1 and 2. Failure to apply the recommended rates and
amounts of Nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application rates and amounts.
APPLICATION APPLICATION
TRACT FIELD SOIL TYPE CROP RATE (iNhr) AMT (inches)
9M 1-1,-2 WAGRAM 0-6% SG 0.60 1 '1
9846 j 1,2 IWAGRAM 0-6% BP 0-60 1 '1
* This is the maximum application amount allowed for the soil assuming the amount of
nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Page 4 of 9

NARRATIVE OF OPERATION
Page 5 of 9

PLANS & SPECIFICATIONS {
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited. Illegal discharges are subject
to assessment of civil penalties of $10,000 per day by the Division of Water Quality for
every day the discharge continues.
2. The Field Office must have documentation in the design folder that the producer either
owns or has long term access to adequate land to properly dispose of waste. If the producer
does not own adequate land to properly dispose of waste, he shall provide NRCS with a
copy of a written agreement with a landowner who is within a reasonable proximity, allowing
him/her the use of the land for waste application for the life expectancy of the production
facility. It is the responsibility of the owner of the facility to secure an update of the Waste
Utilization Plan when there is a change in the operation, increase in the number of animals,
method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for realistic
crop yields based on soil type, available moisture, historical data, climate conditions, and
level of management, unless there are regulations that restrict the rate of application for
other nutrients.
4. Animal waste may be applied to land that has a Resource Management System (RMS) or
an Alternative Conservation System (ACS). If an ACS is used the soil loss shall be no
greater than 10 tons per acre per year and appropriate filter strips will be used where runoff
leaves the field. These filter strips will be in addition to "Buffers" required by DEM. (See
FOTG Stantard 393 - Filter Strips and Standard 390 Interim Riparian Forest Buffers).
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil
incorporated on conventionally tilled cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application does not occur during a
season prone to flooding. (See "Weather and Climate in North Carolina" in the NRCS
Technical Reference - Environment file for guidance.)
"7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
runoff does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control conditions
conducive to odor or flies and to provide uniformity of application.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with
a high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste shall
not be applied more than 30 days prior to planting of a crop on bare soil.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following:
the outer perimeter of the land area onto which waste is applied from a lagoon that is a
Page 6 of 9

component of a swine farm shall be at mast 50 feet from any residential property boundary
and from any perennial stream or river (other that an irrigation ditch or canal. Animal waste
other than swine waste from facilities sited on or after October 1, 1995), shall not be applied
closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal Waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landownwer.
14. Waste shall be applied in a manner not to reach other property and public right - of ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted croplands
provided they have been approved as a land application site by a "technical specialist".
Animal waste should not be applied on grassed waterways that discharge directly into water
courses, except when applied at agronomic rates and the application causes no runoff or
drift from the site.
*16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc.,
shall not be discharged into the animal waste management system.
*17. A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). If needed, special vegetation shall be
provided for these areas and shall be fenced, as necessary, to protect the vegetation.
Vegetation such as trees, shrugs, and other woody species, etc. are limited to areas where
considered appropriate. Lagoon areas should be kept mowed and accessible. Lagoon
berms and structures should be inspected regularly for evidence of erosion, leakage or
discharge.
*18. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
*19. Waste handling structures, piping, pumps, reels, etc_, should be inspected on a regular
basis to prevent breakdowns, leaks, and spills. A regular maintenance checklist should be
kept on site.
20_ Animal waste can be used in a rotation that includes vegetables and other crops for
direct human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied as a preemergence with no other applications of
animal waste during the crop season.
*21. Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to mark
the maximum storage volume fpr waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least
annually at crop sites where waste products are applied. Nitrogen shall be the rate -
determining element. Zinc and copper levels in the soils shall be monitored and altemative
crop sites shall be used when these metals approach excessive levels. pH shall be adjusted
for optimum crop production amd maintained. Soil and waste analysis records shall be kept
Page 7 of 9

for five (5) years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina Department of
Agriculture regulations.
Liquid Systems
Page 8 of 9

NAME OF FARM: Spell Hog Farm `
OWNER ! MANAGER AGREEMENT
I (we) understand and will follow and implement the specifications and the operation and
maintenance precedures estalished in the approved animal waste utilization plan for the
farm named above. I (we) know that any expansion to the existing design capacity of the
waste treatment and/or storage system or construction of new facilities will require a new
utilization plan and a new certification to be submitted to DEM before the new animals are
stocked.
I (we) understand that I must own or have acces to equipment, primarily irrigation
equipment, to land apply the animal waste described in this waste utilization plan. This
equipment must be available at the appropriate pumping time such that no discharge occurs
from the lagoon in a 25-year 1-day storm event. I also certify that the waste will be applied
on the land according to this plan at the appropriate times and at rates that no runoff occurs.
NAME OF FACILITY OWNER: ,D, K. Spell
va
SIGNATURE: ` t DATE:
NAME OF MANAGER (if di rent from owner):
please print
SIGNATURE: DATE:
NAME OF TECHNICAL SPECIALIST: Bryan Spell
AFFILIATION: Dogwood Farms, Inc.
ADDRESS (AGENCY): P.O. Box 49
Clinton, NC 283290049
[phone]
SIGNATURE: � � DATE: 1(,2
Page 9 of 9

E1\1ERGENCY ACTION PLAIT
PHO\E NZttiLBERS
DWQ _ [914) 7T1-r;nR�
EMERGENCY Mi _-�.__; AGEME T SYSTEM
SIX'CD _ [phone]
\hCS [phone]
Tais plan wDI be irnplemtnted in the event that wastes from your operation are lez� i g.
ove-flowing, or r.!nnina off site. You should not writ until wastes react surface water or
leave your property to consider that you have a probiern. You should make effcrt to
ensure that this does not happen. This plan should be posted in an accessible Iocation for
all emplo%ees at the facility. Tile following ar_ some action iterns you sho�_ld tak__
I. Stoo the release of wastes. Depending on the situation. this may or may not be
possible. Suggested responses to some possible problems are listed below.
A. Lagoon overflow -possible solutions are:
a. ,add soil to benni to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop A flows to the lagoon itrimediatel_y.
d. Call a pumping contractor.
e. flake sure no surface water is entering lagoon.
3: Runoff from waste application field -actions include:
a. Immediately stop waste application.
b_ Create a terngorary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. EvaIuate and eliminate the reason(s) that caused the runoff.
e. EvaIuate the application rates for the fields whe;4 runoff occur-,ed.
C. Leakage from the waste pipes and sprnklers-action include:
a. Stop recycle pump.
b. Stop ir-n23tion pump.
c. Close valves to eliminate further dischar?e.
d. Repair all leaks p _;or to restar€ing, pumps.
❑: (<. 2kag�! from flush sysierzis. houses. solid sc':�:ir2!ors-2,:t:on includ_.
2_ Siou re::. C=d nurnic.
�. SCCn ir%Ut!cil YUTi'�0.
:U-f nQ Sl"!lQit 0C=
J. SiU ll U

6: Contact thpe technical specialist who cerified [he lagoon (`RCS, Consulting
a. Name:
b. ]?honk:
l: imnpid-rent Drocedl:;_s as adv;Sed by DWQ aaund t2chnIcJ- assisiarxe acencies to
reciifv t11 dsmagerepair the system' -and reassess the �L'��-_y"t_ manage -me"[ plan CO
ke!:� -,robl-! ns with release of wastes from hat penina _ca',-n. `

Insect Control Checklist for Animal Operations
tiuuret Cnnsc 11MI'as f l G1131r-a1 1115CCIS Site Specifit.. Prucliccs..R - -- —
__ Liquid Systuns
1 11n11 Glrtlers • Accuuullafion of solids Cl 1:Ins11 system is designed and operlled
sufficiently In remove accunullrlled solids from
gollcrs as designed.
n Remove bridging oraccunolklied solids ;it
lll]Cbar6'e
I.sll;rtmis and fits Clusled Solids r1 Maillmin lagnotts, Settling basins 111111 tilts w1wic
hest breading is apparent to olinbrtize the
crosliog of soliels to a depth of oo noire Ilran 6 -
Il inches over morc Own ail ie of surlllrx.
I:ttets5irt Vtt;ttalivt • liceaying veUviatiulr n Maintain vcl;etmive ennllol alttnl, Ilanks of
I ila�tcril Ingrtmns and other impo n dmems to prevent
accrlrllrllatioll of decaying vegetative 1111r11cr
;dnnlI wMel's usage oo illipm u,inlcnl's perimeler.
Dry Systcols
Feed Spillage n I )csign, opermic sum) maiismio Iced systems Ic.g.,
bunktls and Iroli hs) lit milli nlle the
at c ilmilalinn of deealying waslage.
n Clean tilt sltillal,c or1 it rouline basis (c.g,, 7 - 10
day inlcrval rlming sunmrcr; 15-30 day iralcrval
dntiag tVrltlUfl.
Accumalations of feed residues b Itetime umistore acconmiation within soul
nummil immediate lici iuleler of Iced storage
areas by insillsolr sllainap. away Gor11 silt
and/or providing advilimic conwinntent
cnvercd hill filr bre+eel's graill surd Sinlilar 1611,11
oltlisnne grain ploducls).
ri Inspect lilr and remove Ill. break lilt 11CU11mu1alcd
Solids ill filler strips slrluuld feed sloe ge as
needed.
AKIIC - November 11. 1996, Page I

Sontvv
CullsC
IIlltl's III Control Illseeis- Site Specific I'l-adius
Animal I Inlding Alois
Accnlllldatinns of uidmai wastes n-
iilinlinale low areas 11101 Ilan Illuislure a101Ig
and Red wastage
fences and other IIICIIHOFIS wlll:re waste
accumulates anti disimbauce by animals is
minimal.
Cl
h1ainlain fence rows and fillersirills luntind
animal Imilling areas In illirlimize
accumulations of wastes (i.e., insliccl for and
temove or break up nectuuulated solids as
neelled).
Illy I. a u to I landling
Accumislillims of ilrrtlmal Wastes n
Itt`.111nVe Spillage oil a rolltille basis (C.g., 7 - 10
Systems
slay interval dining summer; 15-30 day interval
(luring Wilkie$.) Where manute is ioadctl for land
application or disposal.
rl
Provide fnr mletpiafe Ilraillage around malltlic
SII a-pilcs.
F1
Inspccl for aiul temove of break kill accumulaled
wastes in filter drills arolnld stockpiles and
ularuuc halldliug areas as needed.
For nlElrc Itil'Ormatioll Contact the Caopetalive Extension Service, Depatiilicill of l:ululliology, Ilex 7613, Nnilli Carolina Stale I Iliivctsity,
ItalciUh, NC, 27695•7613.
A h I I C - HiIvembet 11, 1996, Page 2

owine Farm Write, Management Odor Control Checklist
lalllse
�.e.....«..._
llflil's Ia Miliimi'Le 011111. Nile Sllrrifil: I'l wAiccS .._�
1 .unl�l�,uf
• `M'i0C 11110llcliilil
F1
Vel,l.11llivc or wooded Inillt'ls;
I --I
ltecn,ninenticii hest n aungl meld placlices.
n(;omi
jimcnicnl wo cntiln oo sense
•RAninl.11lur�l}':.Iniucl:s �
• 1liily nlaluuc•ciwcrcrl iulNnills
n
Dry 11ilnls
.. __. ..... _ ......._:
I'l
Wka nlauulc•ralti',:I+:11 Iluul ._.._—....f.i..
4
�,----_..—._.._...____..T.......—_..-----...—•----
15mic(i llklm%.
n
waletcis located over sliillcll (lours;
n
1 ceders ill Ilil;ll c1111 of Will Mims;
n
1il:rilpc manare Iniilklill) fio„ 1 Ililms;
ri
I Jildri Ill pot Veil Lit -at illli fill 1ir)'illg
I.I.EIInit: ttlllt.t liknl pit-,
0l11inc;
n
ricgncul manioc feinuvai IIy flush, pit icomll;c.
• I'iillliil„ icilll,lill Ill -cm ill 111skiiIll
orS1YYllc;
n
I IIl1IClllilill' VL'l1lllidlllll
;luilELElr�,kE c'1lliMlSl I.dl�
• Vnlatilk, f, Iso;.
n
I au mai,Iicna,l,x; -. .
NA
n
I:IIIIiCIII .iii- in11v4linari
111.I.EtH )IIIf li C�
I llltil
n
wasi111111V111wi%ves-a I!,mill:i iif i111n1 ms;
n
I•I'8E1 i,rfllliwCs;
FI
Fucticr uoycrs;
1-1
Deed delively Juwnsllllul cslenticci In Il:rili:l
i•1,v1:rs
I-145-.11 i,lld.•.
• Ag;Halllln ul It_Cj'r:Icl! Ial;uon—
C:'1l�1111sh
ti1nl: rnvl•ry; `--------------....---------.".'"..-----_._.__�---_._..
Ikllliil 4\'f[ill: Iillli.S:I,C Illlil,l;
1-1
11Smill fill finks III tllli,t 11lllliklll III'laill's Willi
illltl-SElllillil YC.ttIS
I IIIJI Alcy'.
Agilatinn ilaling tide aler
n
I imit.,Iitior nusi1 will, moe,iimor vtJdam im
r.il,ivcysincc
1'N I.:kll.ul't' lluiiily �- - -0—Agiliilitln ul'ircycled Iill-pon
fiEluiEi wliilc hits arc filling,
Iluting sung) lim - ---
filling and 111mvilowil
�[ lul;i�lk: illaul cnll+.:ihuu • Al;iliillr,ll ,Illfllil; WiISIl:1Vi11E.f
Ekl IIIllllilEll Iliilta Ci1lIVl'}'i111CIi
f 1 lixlcnrl l►:rLlllgc lines Ikl twill Ilulluru ul'llils
with nnti-sillllnll vcllls
CI Sums, uugh i:rwcis
n Ilux t:ovl:ls -
ANil fl' - I luvrmlivi I I, 11196, ll;ice

--w . �...,_..-Ll�ww��.�.�y-parr 1ta�� • r1.4w114. S4.w__-'....a--�.c�L.— - -s_ ._L' _..' 4.�:i A....�.a..�
+•WCoil" Fif411`x in 111itsinlitc {Idnr J.MIC Slocrilic 1,111flices
hill 44 Ilraiallilles al Agilatinn during waslewaler n iixiend discharge Imisa of !lilies mwetnaalh
Lll;tte,u CIIPIveyallce lagnnit liquid level
LIC11r111 sill laces Vablile gas cellissinlls; n I'rnllcr lagoon liquid ellpllcily; — -- —
• lii+llogiul! Iaixiltl;; n cone, lagorrn shim!! ptumittres;
+ Al;ililliun 11 Mininrunl snrlacc alga-lip'
-vl►Itlme, ralill;
171 h ininnlnt agilalinn when Inimping;
(-1 NICCllalliCal aCI.Mian;
rl 1'Inven Ilinlnl;irill-addilive:s
Irlll;:,li„II al,lllll.lrr
Illl;ll llle'islllC al;llilllnn;
1-1
h6gale cm 411), days willi lllllc 11r tell wind;
fell//1[y
w;r„l,I,;II
n
i�'lllt;,t,ell,ell'Culllllll'lglCtllll,l'1i11111g1RL'95111t';
17.1
Pullip intake licar lagnnit llgllid sill Ella:;
11
I'lllllll �Illill Se:Cntld-Stal;C lilgonll
`ilul.f l,L' Lull. all lta'.ilt
• hil lhil 116Crnhi:ll &XI11111105ililill;
C1
Ilnllnlil Ili mitnevo hlitti011;;
,ulLtLc
& hlixilig while filling,
171
Tank ravels;
• Agicifinit whett elllhtytltg
n
Hasill sill race Inats nl SQlllls;
I"1
INnVe:u 11431,11'llall 11111lilives lirllxithills
';�nll,r�; It,�i,i :,nll;,cr
Ex,crul rllait,llille t,rlllcl:; millt•.,Itmilll litillill
I'allial mi, ,lliial ,Iccnnylnsiliim;
C`I
• KIiMinl; while filling;
level;
• Al;ilaliun whim talllllyiiig
n
lieillnve. willed sn4itls te.•l"Wally
Ili ttl ,In,ll'c
• Al;ilmimi w1wil slrrcathoig;
Cl
Snil illiccliun O'slullylshull,cs;
5l„e,l,hl uull,:l5
• %'(dalile gas rnlissitills
n
Wash lesidwil m,lnme linen Spreader idler uw;
n
Illt,ven hiolligilall addilives or fixilhlnls
{ 1111r#lucil manille,
Villalile gas C111issillns while:
n
itlil lnicclitltl 111 SIEIII}'fshlllges
r.hul) nl sln,ll;c ern liel,l
dl)ilrl;
Cl
Slid incnipmalinll wilhill,IN Ills.;
sill 1.1i C•,
n
sim:xii in Thin nnifrltln I:ryels fin rallirl tllyiul;;
f l
11I(wen 11inlligival : ddilivets +u- ttxillaillx
i I,:.r,l apiEH.11ti -----�-��--
(`:lri'a"S dCCltullut5ili[In �
177
I'nllirr disl,[isiliesu elf eanrlcses
itr l,l allt„ 1,11 ,i,'.l"„`u,l
• l'afI:aSS IicutIm114IsIIit)I1
11
Cimilliele e:nvi'.lilll; ill' ci lcasses ill 1,11161 lrils;
l-Ih
11
Pi-til,er Itiralinnh•.nnsun+aiun nl'tlFyuls:ll lrils
In,,1Nr1;t,,u , 1m:11111 111-le cu1111n1slilln n SCCWlllmy slack Ilrutiets
., 101 11 ' - 1 hiveml,r:r 11, 199h. Page •I

w a._- +w._�a.�—w___ __- - __- ^..1 .-.' - •14. �.F.Miaa.�. ��:iiAPiiiiMlikLiis:f � 5ii.-k'1-. ...�w_.._...w.�....�.w_. .t.-....�..�.r.af.w.•
Saul a e IIA1l's Ill Milliluire 041411' ~Site spruilir III;11•lires
^`il.uulglg 1Va1el allslll111 • Ialluollcr drtlillal;e; I7 Goadc and landscal►c such that water thains ..__
Microllial decomposilion (if away fioln IacillUos
(ilgarlic 111,111er
hl.uuue Ira1.1.1:11 t1-1 i'oully 11wiulaiuell access looks
lulilli,: trlall!) fills faun
,Ii�:eSS
Cl film access 101111 maitllcllallcc
Addililmallnl'nunalioll:
%xvine Malkine 61.I11.51;Cnll ll ; 021111 IinICAINIlt Pa1:kcl
S%Vil%C 1 14011Llir)ll I::Ilol POICIIIial t hiar Sowccs and I(cme;lics ; FUAV Fact Shed
ti)%Vm: I`millrctiun Facitity MannrC KbIlit;;c1111:111: Pit 1ic1:11a11;e - l.aUnon'I'rernnlenl ; FIlAF 128-118
`;LVifIC VIMILICIi,lI, 1:061ily Allunrle Mmial;emcul: thulclllunr Flush - 1.11gnnn'I'Iclument ; IAIAli 129-HR
I►csil;n 111111 ht:urll;enlenl fur hvcslock Minute TleI11ulenl and !ilnral;e ; laiAF 1113-113
I '.IIIN.11iun of, Mauna: and iAWamewaler Alllllicalion I-yuillmeat ; 1:11AE acl .Sheel
s'momillml;11,1urs Boni Swinc 11oikhoigs ; 1411-33
1:IIt•I1„II,n1 trial Asswallce I otpam ; NPI'C, Mi111E1O
I llin+ins lur AIIlllal;iiy, ( Our ; i, Iepim Illnll Illc Swlnc Will- I osk Force
I IILP.A111-C ( IIIICIAII�, in Aliinllil Aianme Mallty;cnrcnl: 01111rs an11 Flies ; 11Itl ll(P. 1995 (.'nul'eiim :c Illorecllings
Avail:lllll: FInm
I11'SI J. t immy I:xicltailm I'clux.I
11CS11 - IIAL
FICS1I- IIAI:
1J1'NI I - HA1.
11CSII - IIAI:
1.11',;I 1 - Swine IixlelI.6111
M' his PjmIt1ccls Assoc
NI';;I I AI;Ii I'numiullicnliiiIi%
Holida t'nufu Ialivc I•:alcllsinn
ANO 11' - tl.1v.:nil,i, I I. I'1,l(I. I'nt;c 5

tilortality 1lana2ement -Methods
(check whic: me:hcd(s) are being implemented)
J Burial three feet beneath the surface of the ground within 2= hours after
know•ledve of the dewth. The burial must be at least 300 fee: frorn any flowing
stream or public body of water. r
rl Readering at a rendering plant liccased under G.S. 106-163. i
! Complete inc:ner--L;.Cn
❑ In the case of deed poultry only. piacing in a disposal pit of a size and design
approved by the De=. M-n=E of AgnculFure
''Zi Anv method which in the professional opinion or the State Vere:inarian would
make Possible the salvage of pan of a dead animal's value wi=.Haut cidaneerinQ
human or animal health'. (Written approval of the State Ve:e:=nay-ion must be
attached)

Unitea States Sod
{+_• � aeoartment of Canservation
Agriculture Service
LAGOON NO, 1
OPERATOR: 0_K_ SFFi.i
Please review the attached plan and specifications carefully. Retain
this plan For your use and records. It is strongly recommended that you,
your contractor, and Soil Conservation Service personnel are in agreement
as to how the waste lagoon is to be constructed. The Soil Conservation
Service personnel will meet with all concerned parties and walk over the
site to explain all Flags and markings. It is important that everyone
understand what is expected so that final construction meets plans and
specification and the job can be certified For payment (iF cost -sharing
is involved).
The pad dimensions and grades are the best estimate. The BUILDER or
CONTRACTOR is RESPONSIBLE for final layout and design of the pads. The
Soil Conservation Service personnel will assist in a limited capacity,
as its major concern is the proper design and construction of the waste
treatment lagoon.
t
The actual amount of material repaired for pads and'dam may vary from the
estimates. The design will attempt to balance cuts and fills as close as
possible. If additional material is required after construction is complete
on the lagoon, the contractor and owner will negotiate on the Price and
location of borrow area.
NOTE: Design Requirement: 117,893 cu.ft. = 4,366 u.yds.
Estimate of Excavation: 9C�8 cu.ft. = 3,574 u.yds.
Estimate of � Dike: 68,661 cu.ft. = 2,543 u.yds.
g.4: 1 Ratio
.lob Class _z '/ / 71 ?dT
Date
Designed By HERMAN RTGGS
Name
Design Approval
Name
Data
The Sag Conservation Service
Vis in agency at the
0e0artmenr or Agrrcunure

'tv
7rj

.
' !VAI1E : !7 . w::. S P E L L
•.1JI?Filx's5 : =L i NTON , MC:
TYPE AND SIZE 6cE(-f TOPPING
OF OPERATION
CLASS
DESIGNED BY HERMAN RIGGS
DATE 3/ 3 1: ,3,3
APPROVED BY
DATE
PE MAMENT STORAGE
6ZO Hogs x 135 I bs per hog 1 Cu Ft per lb.
TEMPORARY STORAGE
83TOO I bs of animal x 1.35 cu. ft. of waste per day
per 1000 ibs of animal wt. x 180 days
RAINFALL LESS EVAPORATION
7" X Z3750 sq. ft. surface area per It"per ft
RAINFALL - 25 YR. 1 DAY STORM
7" X Z3750 sq. ft. of surface area per 1'Z" per ft.
TOTAL STORAGE NEEDED
TOTAL STORAGE AVAILABLE
AMOUNT OF FILL DIKE O Cu Ft
PAD ERROR Cu Ft
TOTAL ERROR
SETTLEMENT 10% ERROR
TOTAL AMOUNT OF FILL ERROR
ERROR
8'-370 Y Cu Ft
20:339 Cu Ft
13854 Cu Ft
1:3854
Cu
Ft
117893
Cu
Ft
4366
Cu
Yds
119061
Cu
Ft
0
Cu
Yds
Cu Ft
Cu Ft
Cu Ft
Cu Yds
CUT TO FILL RATIO TOTAL E:<CAVATION ERROR Cu Ft
ERROR : 1 ERROR Cu Yds

NAME: D. K. SPELL
DEPTH EAREA OF TOP + AREA OF BOTTOM + 4 X AREA OF MIDSECTION]
VOLUME=-----------------------------------------------------------
6.0 27
DEPTH I L X W+ L X W+ 4 X L X W I
VOLUME---------- ----------------------------------------
7
�90 x I C=�,s.oc -roa)
L 1 78 N1,
1 13 '� 1 �'� XJ �� +4 i � 15 1 ii ='ti 6
VOLUME=---------- --------------------------------------------------
6.0 27
9.0 1 793743
VOWME =-----------------
6.0 27
119061.0 GU. FT.
VOLUME =---------
Z7.0
VOLUME = 4409.7 GU.YDS.
Z3750.0 sq.ft.
117393.3 cu. ft. needed
SIDE SLOPES 3:1

Confinement Bvilain,c
ICAL VIEW OF A ONE -STAGE LAGOON SYSTEM
LAGOON # 1
Top Width 121
=eC:-ace Top Elevar,ion
Fluid E i e v a t i .- r,
Pi:,
SS 3
TREAT14MI'T
" LAGOOR
V
" Pipe (Needs to be adequately Depth
supported)
5ottain Elevation 37_.::_

e,
U.'S. DEPARTMENT OF AGRICULTURE NC-ENG--;0
Soil Conservation! Service 5/83
LOCATION CODE
�E
II PLAN OF EXCAVATED WASTE STORAGE POND
i
NAME D. K Spell ACP # DATE 4/5/88 DISTRICT S TIE
psQZ
i
t 1901
L ENG TF!
SIDE SLOPE -1-TO i
I �
n V 4vE. TOP ELEv. �q`�
O •
( SECTION
o �� {YE. 30TTOM ELEV. I
t59
_ L EN G `H
- 12_~mil
Volume depth Carea of. top) + (area of bottom) + (4 x area midsection] - 11% of,1 Cu.Ft.
6
i
SUMMARY
Use of facility ANIMAL WASTE LAGOON
Capacity 8 J-0 ,57 c _ Gallons
Volume Cost -sharing Cu. Ft.
Soil type Wazram 370B
B. M. description 12d nail in 31' pine
tree near p/1 approx 2501 right
of c Lime
Assume Elev. 50.0
Bottom Elev.
Normal liquid level Elev.
Storage for normal precip.(Ft) +
Maximum liquid level Elev.
46
Storage for:
25 yr. freq. precip. (Ft.) + 1.0
Crest ESW Elev.
Stage (Ft.)
Freeboard (Ft.)
Top of Dam
+ 1.0
Elev. _ 48.Q_

idAJ�. E .
Ar !MATE NI—TR13GEN C:l- IN -=NT PHA T AILL L-:E PR IDUCEI E'ER Y4AR;
N I TROGEN (N) — 0.48 Li S PER1 ic�ca LSS OF ANIMAL WT . ;: 'Gr , , DAYS
(N) — 0.4. .c ,33700 :360
----------------------------------
1 () c i C)
(N) — 146 r.4 _ 24 LSS
IT IS ESTIMATED THAT APPRO"IMATELY 'Z5 % OF THE NITROGEN WILL BE
A V A I LAB.LZEE =FR iJ'Id E AS F ERT I L I ?ER
THE FOLLOWING AMOUNT CAN BE APPLIED ON THE LAND
3666.06 LBS .
IF APPLIED AT THE RATE OFZOO LSS PER ACRE ON CROPLAND THEN
18.; S:0-3 ACRES WILL LIE NEEDED TO TAKE CARE OF THE EFFLUENT.
IF APPLIED AT THE RATE OF 400 LSS PER ACRE ON PASTURELAND
9.1651E ACRES WILL BE NEEDED TO TAME CARE OF THE EFFLUENT.
BEFORE ANY EFFLUENT IS APPLIED TO THE LAND IT SHOULD BE ANALYZED
TO DETERMINE THE EXACT NUTRIENT CONTENT. THE NCDA LABORATORY
IN RALEIGH IS MAKING SOME TEST ON A LIMITED BASIS. YOU SHOULD
CONTACT
AGRONOMIC SERVICES DIVISION
NCDA, BLUE RIDGE ROAD CENTER
RALEIGH N.C. Z7611
PHONE: 919-72.3—Zds55
WHEN APPLYING THE EFFLUENT TO CROPLAND IT SHOULD BE DISK AND A
COVER CROP SEEDED OR A ROW CROP PLANTED TO PREVENT EROSION
SOME OF THE EFFLUENT COULD BE USED FOR IRRIGATION PURPOSES
DURING THE GROWING SEASON.
BEGIN PUMPING THE EFFLUENT WHEN
THE FLUID LEVEL REACHES
DO NOT LOWER THE FLUID ANY
LOWER THAN
�t.SC+t++.r71n� A►p 6 3
�v ' a CLn w J��sL4w,+�wF APES

NAME:
SEEDING SPECIFICATIONS
AREA TO BE SEEDED 0 AC.
APPLY THE FOLLOWING
0 LDS. S-8-8 FERTILIZER
0 TONS DOLOMITIC LIMESTONE
0 SALES SMALL GRAIN STRAW
USE THE SEED MIXTURE
INDICATED
(
)
D
LDS.
FESCUE GRASS
(
)
O
LBS .
OATS
(
)
0
LDS.
DAHIA GRASS
(
)
O
LDS.
WEEPING LOVE GRASS
(
)
0
LES.
HULLED BERMUDA GRASS
f
)
O
LBS.
UNHULLED BERMUDA GRASS
DIVERT ALL WATER TO A STABLE OUTLET
THE NEAREST RESIDENCE IS 1 5 c FT.
T.B.M. ELEVATION So cc
DESCRIPTION

U. S. DEPARTMENT OF AGRICULTURE
Soil Conservation Service '
NC-ENG-12
Rev. b/82
EARTHWORK COMPUTATION SHEET
EARTH EMBANKMENT
Name _
Address
Embankment: Top Width
Side Slopes
STATION
FILL
HEIGHT
(.Feet)
END AREA
(Sq. Ft.)
SUM OF
END AREAS
(Sq. Ft.)
DISTANCE
( Feet)
DOUBLE
VOLUME
(Cu. Ft. )
tom-•
�J f
..Y�.—
/
7.V
3
9 37
�7
j
f—z" L.
1 70.
+9
.S -r
f
�
n
fi
I. Double Volume of Fill - 2 = .1,_ ;, Cu. Ft.
2• Volume of embankment fill (line 1 t 27) _ L 3 1 , Cu. Yds.
3. Allowance for settlement (5 or 10% of line 2) _ 3 Cu. Yds.
4. Total cubic yards (line 2 + line 3) _
5 ¢3 Cu. Yds.
Computed by Date

77.1c. SPELL Aw L '0-- 1
STATION
STATION ( 8 )
STATION ( c )
STATION ( )
BACKSLASH
FORWARDSLASH
BACKSLASH
FORWARDSLASH
BACKSLASH
FORWARDSLASH
BACKSLASH
FORWARDSU
4-
-7 3�3
P, Q�- 7
J31-7-1
906
-77
77
o6
3z
5-14 5
lo
5143
%a65
/ 883
6510
5—lel3
4�i7-
38-=l13
96,-s
g000
4�S
�' 25
z_s
7z7S
5�43
a
3700
'
TOTAL
TOTAL
TOTAL
TOTAL
TOTAL
TOTAL
�Cp6 3 8
2 f 3 z
2-7 56
� d P9
4L5'2- 79
S- 7 9a /
2-7 65"ea
2 $489

NC-ENG-17a
8/72
END AREA COMPUTATIONS FOR DAMS - COORDINATE METHOD
U.S. Department of Agriculture
Soil Conservation Service
Location
Site
Computed By
Date
Watershed
Item
Checked By
Date
Remarks:
Sta. l,i,vr-
Elev.
G.R.
T.W.
D.E.A. (1) x
.5 —
E.A. ( %47 )
4.5 .37 .37
5?3
Sta. 6
Elev.
G.R.
T.W.
D.E.A. ( LS3' ) x
.5
E.A. ( 4Z0 )
23.8 3- 7
I'L
a2s
12o +3 q 114
a i7j,
zo o
Sta
Elev.
G.R.
T.W.
D.E.A. ( Z(� 2.3 } x
.5 —
E.A. 13 1 2— )
U19 3-7 3-7
1-65
40.E
Sta. LiN6 P
Elev.
G.R.
T.W.
D.E.A. (_ 83� ) x
.5 -
E.A.
�L 2- 3-7 37
41
I'tz
-
1.25 /39 -.a1
.b
"

C

F.
United States Salt LAB• 4'"t #� 2"
Oecanment of Conservation
Agriculture Service
OPERATOR: n_x_ 4PF.LL
Please review the attached plan and spec 1 F i ca t i ons carefully. Retain
this plan for your use and records. It is strongly recommended that you,
your contractor, and Soil Conservation Service personnel are in agreement
as to how the waste lagoon is to be constructed. The Soil Conservation
Service personnel will meet with all concerned parties and walk over the
• site to explain al flags and markings. It is important that everyone
understand what is expected so that final construction meets plans and
specification and the job can be certified For payment (if cost -sharing
is involved).
The pact dimensions and grades are the best estimate. The BUILDER or
CONTRACTOR is RESPONSIBLE for final layout and design of the pads. The
Soil Conservation Service personnel will assist in a limited capacity,
as its major concern is the proper design and construction of the waste
treatment lagoon.
t
The actual amount of material required For pads and'dam may vary from the
estimates. The design will attempt to balance cuts and fills as close as
passible. If additional material is required after construction is complete
on the lagoon, the contractor and owner will negotiate on the price and
location of borrow area.
NOTE: Design Requirement; 116,919 cu.ft. = 41,330 u.yds.
Estimate of Excavation: 94,851 cu-ft. = 3,513 cu.yds.
Estimate of Pad2; Dike: 75,492 u.ft. = 23,795 cu_yds.
1,3 : 1 Ratio:
.lob Class
Date
Designed By HERMAN RIGGS
Name
Des i gn. Approva l .�
Name
13 1 $8
ate
The Saa Caniervatian Serwce
is an agency of She
Qeoartment at ,tgncuitwe

- `_,i-,y:;. ' �•�'7.`"%:.a' � _ `7 ir.—_ � mot. : ' J
,�.;�.•. ��:- .T�. - mot':;
_ _ - _ s. ,'•,'s'�./ - .y � y �• as'...- i�;,� � � by
_ '�: :. . s k - •�� 'fir . i a+ � � � �.•l+•+' � � �'.A,
`t`_,r",N � ' - _ _ +«�-���ss-.T �. ice' "i�" '• '•,..
r �� •�e'}y_.�f �a.�s`���'�,,h yY�}�•�.�t-�7'.i :='" �� r� ssifi4.s'' ;�. - =-^d" .',,
�-f ,yid _�� r- •��.rF. - �- .�.� _�
_-_�•�r.��r"' . _ .� yr_ 1
f•.•.+..- _ gib.' __
::•::�a•1+4

NAME: D . V . SPELL LAGOON NO.
ADDRESS: 'LINTON, NC
TYPE AND S 17E 6ZO T1=1PP I NG
OF OPERATION
CLASS
DESIGNED BY HERMAN RIGGS
DATE 3/ =.1 /`-_8
APPROVED BY
DATE
FERMAMENT STORAGE
620 Hogs .. 135 I bs per hos 1 Cu Ft per l b. :_:3700 Cu Ft
TEMPORARY STORAGE
33700 Ibs of animal x 1.35 cu. ft. of waste per day 203 9 Cu Ft
per 1000 lbs of animal wt. x 180 days
RAINFALL LESS EVAPORATION
7" X 22080 sq. ft. surface area per 12"per ft 1Z73:30 Cu Ft
RAINFALL - Z5 YR. 1 DAY STORM
7" X 22030 sq. ft. of surface area per 12" per ft. 12330 Cu Ft
TOTAL STORAGE NEEDED 116919 Cu Ft
4330 Cu Y d s
TOTAL STORAGE AVAILABLE 121c�:38 Cu Ft
O Cu Yds
AMOUNT OF FILL DIKE 0 Cu Ft
PAD ERROR Cu Ft
TOTAL ERROR Cu Ft
SETTLEMENT 10 ERROR Cu Ft
TOTAL AMOUNT OF FILL ERROR Cu Ft
ERROR Cu Yds
CUT TO FILL RATIO TOTAL EXCAVATION ERROR Cu Ft
ERROR : 1 ERROR Cu Yds

NAME: D . K . SPELL
DEPTH C AREA OF TOP + AREA OF Lit tTTOM + 4 }; AREA OF MIDSECTION 3
VOLUME=--------- ----------------------------------------------------
r.C) �?7
DEPTH C L ;: W + L X W+ 4 ,: L ;; W 3
VOLUME= ---- - ---------------------------------------
27
t j.0 x i 3Y Cram)
)" '.3^- V 5 vi 933
VOLUME--------------------------------------------------------
6 . 0 27
11.0 1 634S 3
VOLUME = ------------------
6.0 27
1'c160S . 0 CU . FT.
VOLUME =---------
27.0
VOLUME = 4505.1 CU.YDS.
22087.0 sq.ft.
116913.1 cu. ft. needed
SIDE SLOPES 3:1

NAME:
SEEDING SPECIFICATIONS
AREA TO BE SEEDED
APPLY THE FOLLOWING
USE THE SEED MIXTURE
INDICATED
( )
DIVERT ALL WATER TO A STABLE CUTLET
0 AC.
0 LBS. ;-=-8 FERTILI ER
TONS DOL? IM I T I C LIMESTONE
0 BALES SMALL GRAIN STRAW
0 LBS. FESCUE GRASS
0 LBS. CATS
0 LBS. BAHIA GRASS
Q LBS. WEEPING LOVE GRASS
0 LGS. HULLED BERMUDA GRASS
0 LBS. UNHULLED BERMUDA GRASS
THE NEAREST RESIDENCE IS -75 0 FT.
T.S.M. ELEVATION S Q-"in
DESCRIPTION IZd gn;L irn 8" Pine 4-ree nea. r-op-&r* C;te

NAME:
AF'F'Ri=I) I MATE NITROGEN (--:I-- INTENT THAT WILL BE PRODUCED PER YEAR
NITROGEN (N) - 0.48 LES PER 1000 LBS OF ANIMAL WT . )< :_65, DA YS
(N) - () . 4:3 x 8,3700 .. 36,,5
----------------------------------
1000
(N) - 1466;:-4 . r74 LLS
IT IS ESTIMATED THAT APPROXIMATELY .L,5 % OF THE NITROGEN WILL BE
AVAILABLE FOR USE AS FERTIL17ER
THE FOLLOWING AMOUNT CAN BE APPLIED ON THE LAND
3666.06 LES .
IF APPLIED AT THE RATE OF '2Ou L13S PER ACRE ON CROPLAND THEN
15.3303 ACRES WILL BE NEEDED TO TAKE CARE OF THE EFFLUENT.
IF APPLIED AT THE RATE OF 400 LBS PER ACRE ON PASTURELAND
9.16515 ACRES WILL BE NEEDED TO TAKE CARE OF THE EFFLUENT.
BEFORE ANY EFFLUENT IS APPLIED TO THE LAND IT SHOULD BE ANALYZED
TO DETERMINE THE EXACT NUTRIENT CONTENT. THE NCDA LABORATORY
IN RALEIGH IS MAKING SOME TEST ON A LIMITED BASIS. YOU SHOULD
CONTACT
AGRONOMIC SERVICES DIVISION
NCDA, BLUE RIDGE ROAD CENTER
RALEIGH N.C. Z7611
PHONE: [phone]_-. �15
WHEN APPLYING THE EFFLUENT TO CROPLAND IT SHOULD BE DISty. AND A
COVER' CROP SEEDED OR A ROW CROP PLANTED TO PREVENT EROSION
SOME OF THE EFFLUENT COULD BE USED FOR IRRIGATION PURPOSES
DURING THE GROWING SEASON.
BEGIN PUMPING THE EFFLUENT WHEN
THE FLUID LEVEL REACHES------------------------------
4
DU NOT LOWER THE FLUID ANY
LOWER THAN

1 . S. DEPARTMENT OF AGRICULTURE' �~ yC-FNG- 4 C)
Soil Conservation Service 5/83
LOCATION CODE
I PLAN OF EXCAVATED WASTE STORAGE POND
NAME _ D. K. Spell AC? # DATE 4 /$$ _ DISTRICT _ amn,;nn
L E to G IN 1601 (-nu412 E T'D 9 1
i SIDE SLOPE 3 To t
}
I /
= 11
138 48.0
A1vE. TOP ELEV.
CY o
W 3f ,` _�MIO SECTION
1.3
f a�aT TOW ELEV.�' I
b 0
/ LEmGTH -7 J
82*
Volume - depth [area of top) + (area of bottom) + (4 x area midsection s 1;Lj� rd s Cu. Fr.
6
Use of facility Anima,j�Wasr� ;RQ]3_
Capacity o gs 2- Gallons
Volume Cost -sharing
Cu. Ft.
Soil type Wagram 370B _
B. M. description 12d nail in 8" pine
150,
of c line
Assume Elev. 50.0
SUMMARY
Bottom
Elev.
3� a!5
Normal liquid level.
Elev.
46
Storage for normal precip.(Ft) +
Maximum liquid Level
Elev.
Storage for:
25 yr. freq.. precip.
(Ft.) +
1.0
Crest ESW
Elev.
Stage (Ft.)
+
Freeboard (Ft.)
+
1.0
Top of Dam
Elev.
43.0

5CS—ENG-539
Ray. S- 70
U. S. DEPARTMENT OF AGRICULTURE
SOIL CONSERVATION SERVICE
SOIL INVESTIGATION TO DETERMINE SUITABILITY OF PROPOSED POND SITE
FA.RMER'S NA .a,.
1"' COUNTY
• • .•
CROPLAND ACRFS PASTURE— ACIZES
WOODLAND • •. WORK UNIT CONSERVATIG—IST
SKETCH OF PROPOSED POND SHOWING WHERE 13ORINGS
■
TT
r
■■■a■�M
Mr..
■
NONE
W.
SON■■■■■■
no
-Ism
,
MUM1■,011®,n�o
�lE�`■f■��■■■
rl■��f■I■f■f■i■f�l■f■�■I■fri■
IMIMMOKIMM
,■
■E■1■f
■I■
MMIMIMI■i■i■I■IEIm
I■■It
��
■E�
tr
■IElm
�l�■i■!■
■fti�f■f�

• U.'S. DEPARTMENT OF AGRICULTURE NC-ENG-12
Soil Conservation Service Rev. 6/82
:4�=
EARTHWORK COMPUTATION SHEET
EARTH F.M$AMfEN'T'
Name -D. K. 5 P'SL.L-
Address =Ei--
Embankment: Top Width
Side Slopes
STATION
FILL
HEIGHT
( Feet)
END AREA
(Sq. Ft.)
SUM OF
END AREAS
(Sq. Ft.)
DISTANCE
( Feet)
DOUBLE
VOLUME
(Cu. Ft. )
�-s�s►
t . C7
] 'r
2�so
3.T
67.3
13 7o S
2�9Ce
S
5
¢oS
�p
�D 2zr-
-�-
4 G
4.4
Z�
5�7 G�
Sri
23 8,� o
3-i4 C.
-T- 8
2 7 L
i o3
t B Q
4�z-7
` 7
3z_
c ,�
4(-Q
r-/-3�
4-7
� 17
3.7
a
14.6
a���,
l �
73
1 zc?—
Q. 4...
w3. !-
1. Double Volume of Fill y 2 - 6 8 6 3 (- Cu. Ft.
2. Volume of embankment fill (line 1 + 27) - �2-S gz:L Cu. Yds.
3. Allowance for settlement (S or 10% of line 2) = ,2S ¢- Cu. Yds.
4. Total cubic yards (line 2 + line 3) = 4 Cu. Yds.
Computed by Date 4-15-I g g

STATION ( )
L
STATION ( B )
STATION ( )
STATION
BACKSLASH
FORWARDSLASH
BACKSLASH
FORWARDSLASH
BACKSLASH
FORWARDSLASH
BACKSLASH
FORWARDSL
8Q�
��311
-75S;
S$ 3 S
99/Z
`r
/��I��I
7735
4 9 Ora
7-735
qo 6/
9 zJ�
;3��
3cau
�-�Co
g ino
o
U-- Z.o
ZAv
467s
38
-7�7 S
U-965
4-7 0 3
ZS'
TOTAL
TOTAL
TOTAL
TOTAL
TOTAL
TOTAL
2a_72�.
���n�3
33 -7T(
l512CL
a

0
NC-ENG-17a
8/72
END AREA COMPUTATIONS FOR DAMS - COORDINATE METHOD
U.S.-Department of.Agriculture
Soil Conservation Service
Location
Site
Computed By
Date
Watershed ]Item
XkK_Spe« Aw, --til-2.
Checked By
Date
Remarks:
Sta. l-.ju67 CA Elev. G.R. T.W. D.E.A. (_j82 ) x .5 = E.A. ( �;
y -9- q-Z,� f
100 t 3 9 194 z a_D I00
Sta. 1.EAIr. {3 Elev. G.R. T.W. D.E.A. (1 6& x .5 E.A. ( (�
y 4r~ 4 1 S 4 44
i I n 13 9 I '? i hn Zpb 110
Sta. L Elev. G.R. T.W. D.E.A. ( 32-3Z x .5 - E.A. (
e4 q 3S 3
6i5 2 :2 25a 2aa 15a 95
St.a. D Elev. G.R.
I2b
T.W. D.E.A.
S ) x .5 E.A.(

OOnfinceTIt Fuilaing
TYPICAL VIEW OF A ONE -STAGE LAGOON SYST123
LAGOON # 2
Teo Width 12t
Pipe (heeds to be adequately
supported)
Fluid E1_evat "
fF
I,' SS 3 : 1
)' /TREATHEINIT
I- AG00N
U
Bottom EI(,atia!, 35
Depth
t J
sec!--led Too Elevation
—I—

fp
._.._ _ . 9�L_. _99`..3-_-__.--•----__5!�-
.__ _
32
8,,.- .
5z.g._.--.---..----.
�3..'i_ .,_._-.--_
_.i4��----._... _.74;q_ - .
34.6
36.3

w_ ..s_l_!.i_l.� ' •� -t-~ - -=- -+.. - t-- ..:.;-i-•t -- i.. _.... .; _ .�.r. _ _ �: r..f. -;� T � y•,Y•, � � --�-J- ��-i-
� ip-� � 'i-.�•1.• _��. ,{{��� .�• 1-.�..� .. - - - ._, .f.... _ .I 1,. I i T^, � � I J w_�'� ,!R j.�'-..t_' .
-f t •r---_j�--� -•t j-._ .� . .�. ..F - -� - - ----.�.._ .}'• . j •i_-:. - -- - -_ '{'•i-, -i-•=-�t-t-�-T-�--i-•f�••-:-- - � }• •{-•� j �_i�_.{.�:.�
17_i
!-�.�-•.�.__� i ._..�_:...1-. _, _ .!. i_ t_t_}..s_., _f-. ,._l..j_ � ._,_:.. . }. � -...F . � �.., _. .� ��: •-•��-i-1 �F-4 ---� f "'���"���SSS �-1-- •l.i:•_;
. _ - ,ice .. ,_ �-° - - . _ � .. ._ _ �a..i,� - _ ... _. ... _ _ •��
-9 foa 4ioo
�! A ✓✓N6 L
0+o6 Iroc) :fit-o
-3too
30
C)-00
I+OO .Zr GO 3+cam
�lPL� !D
y -�.

D . K - SPELL
CLINTON, NC
THIS FARM CONSIST OF THE FOLLOWING SOILS:
21EB AND JOHNSON (211)------------ _ AC EE
WAGRAM ; T03)---------------------- Z4 ACRES
NOTE: l I L- B AND J OHNSE_ N SOIL'S .ARE LISTED AS WETLAND SOILS IN
SAMPSON COUNTY AND FREQUENTLY FLOODED.

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
D.K. Spell
Spell Hog Farm
2420 Five Bridge Road
Clinton NC 28328
Dear Der -wood K. Spell:
17
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
February 28, 2000
Subject: Application No. AWS820427
Additional Information Request
Spell Hog Farm
Animal Waste Operation
Sampson County
The Non -Discharge Permitting Unit has completed a preliminary engineering review of the subject
application- Additional information is required before we can continue our review. Please address the
following by March 29, 2000:
1. Please submit an Operation and Maintenance Plan.
2. Your Waste Utilization Plan (WUP) incorporates current guidance allowing for up to 75
pounds of nitrogen per acre to be applied to small grain overseed (grazed) under strict
management practices. As mentioned in the enclosed guidance memo the last application
to bermuda must be prior to August 31 and the last application to small grain must be
split applications but no later than March 31. Currently your WUP lists the application
window for Bermuda as March through October and the application window for small
grain as September through May. These application windows should be revised to reflect
the current guidance for application to small grain overseed at increased amounts.
3. Best Management Practices (BMPs) that are to be implemented at this facility should be
identified (check the appropriate BMPs) on the Insect Control Checklist, Odor Control
Checklist and on the Mortality Management Checklist.
4. Please provide a clear map that identifies (outlines or highlights) and shows the acreage
for each field to be used for waste application.
Please note that all WUP revisions must be signed and dated by both the owner and the technical
specialist. Please reference the subject permit application number when providing the requested
information. All information should be signed, sealed, and submitted in duplicate to my attention at the
address below. The information requested by this letter, must be submitted on or before March 29, 2000
or the Division will return your application as incomplete in accordance with 15A N.C.A.C. 2H .0200
and your facility will be considered to be operating without a permit.
1617 Mail Service Center, Raleigh NC 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50%0 recycled/ 10% post -consumer paper

Application No. 82-0427
Spell Hog Farm
Page 2
Please be advised that operation of the subject animal waste management system without a valid permit
is a violation of North Carolina General Statute 143-215.1 and will subject you to the enforcement
authority of the Environmental -Management Commission.
If you have any questions regarding this request, please call me at [phone]. extension 502.
Sincerely,
'Sue Homewood
Environmental Engineer
Non -Discharge Permitting Unit
cc: Fayetteville Regional Office, Water Quality
Permit File

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
D.K. Spell
Spell Hog Farm
2420 Five Bridge Road
Clinton NC 28328
Dear Derwood K. Spell:
V 71
•
A1 •
NCDENR
NORTH CAROLINA DEPARTMEN'i of
ENVIRONMENT AND NATURAL RESOURCES
May 30, 2000
Subject: Application No. AWS820427
Additional Information Request
Spell Hog Farm
Animal Waste Operation
Sampson County
The Non -Discharge Permitting Unit has completed a preliminary engineering review of the subject
application. Additional information is required before we can continue our review. A request for
additional information was sent on February 28, 2000 and to date this information has not been received.
Please address the following by June 30, 2000:
1. Please submit an Operation and Maintenance Plan.
2. Your Waste Utilization Plan (WUP) incorporates current guidance allowing for up to 75
pounds of nitrogen per acre to be applied to small grain overseed (grazed) under strict
management practices. As mentioned in the enclosed guidance memo the last application
to bermuda must be prior to August 31 and the last application to small grain trust be
split applications but no later than March 31. Currently your WUP lists the application
window for Bermuda as March through October and the application window for small
grain as September through May. These application windows should be revised to reflect
the current guidance for application to small grain overseed at increased amounts.
3. Best Management Practices (BMPs) that are to be implemented at this facility should be
identified (check the appropriate BMPs) on the Insect Control Checklist, Odor Control
Checklist and on the Mortality Management Checklist.
4- Please provide a clear map that identifies (outlines or highlights) and shows the acreage
for each field to be used for waste application.
1617 Mail Service Center, Raleigh NC 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Application No. 82-0427
Spell Hog Farm
Page 2
Please note that all WUP revisions must be signed and dated by both the owner and the technical
specialist. PIease reference the subject permit application number when providing the requested
information. All information should be signed, sealed, and submitted in duplicate to my attention at the
address below. The information requested by this letter, must be submitted on or before June 30, 2000
or the Division will return your application as incomplete in accordance with 15A N.C.A.C. 2H .0200
and your facility will be considered to be operating without a permit.
Please be advised that operation of the subject animal waste management system without a valid permit
is a violation of North Carolina General Statute 143-215.1 and will subject you to the enforcement
authority of the Environmental Management Commission.
If you have any questions regarding this request, please call me at [phone], extension 502.
Sincerely,
ue Homewood
Environmental Engineer
Non -Discharge Permitting Unit
cc: Dogwood Farms, Integrator
Fayetteville Regional Office, Water Quality
Permit File

Q
t49
fit
()'t}
C,
go C3
qtr .r: »rs1
t.l�, rll O
n, t�. L- i}+�? [} W
ni Ilt
NUN
tip ,iJ
on )1
13
-
-- Wl
�_ []► — ."
-t 3 1 tl)
_n
LI +n
IIJ
-1-- 111
-LtIh
•r
L -i7 -
-
,j rn -} L N .(� E- r, tit
IU j`. .L.
l!I
.� rlj
ldh,- :y•t.-t1 Ill rl)
ru .: ;_ t ru
V ,]fl
(itr �-
IJr)
t:
. .r]
oil tit
.. n.
`S•
i7 L7.
_
1!1': �� ui 1 'rtt �1( I rT
'
Ifr
Ln
W
N
_LY rtf •- -1- IJ
ru +n QI
toff t.l
1_ Itl +tS
11)
,_t
nl ci
11) 1- tll
1
to 1- "' - i iu ilia �;, �-
[r)
( rr 1)
t1i "' >'
to
in
IJ .�
1)
rti i' Fri 11)
7 IL) �?H
I: u 111
U
�. (Il rt1 • c; _C?
SS ]
tW 1.3
ru C
bij e,'
>
It
I!) '.� t' Ill _� •.
l._
tu
'
t[i
I_7 rV tZ►.a1= I �.C) f,
1.1 iu
61)
tll.t.
L) -. >
:
rtl [
{� rtl � -
fV
Cf~
Ul
T �l I (} .s
T'�
(IJ
•
IU
Q
k1�
tll.v,
,n ry ♦�`- _J• .1 ,-;
7 •__ G. (1 w Ill (t1
v [. (]•fli
rtt 1:
c its
`� iv
: -z .'� . r_ F r7 •J) ?
iv id 5(.). IU 1-- oil�?
A. ri '
U
�..__
.
iu E u± c3, cJ ;_,
r 7 0
�i ,1'
Z? Irt
' Lf i J
U. too'
U _() �)� t )••� t1) rV t; ---
t!� C7 ia' . ' at C1 :-
W fit) " 1
-- cU (1) . U
iU
,
C) C
too +n v► .._ tf Cl •'
too
tt) .� .:..c)
I :•
1_
iv L) ]. , , E_ 1- <1) tuJ go I-,
;J '� (% ��1f_ rtl
C) in
C
rU
()
CI CJ ,n
bfY
(i. �1 fll
tM
- ')-C7
i..
rt1 [ U
11) It, i�J _In
i_- hb'C7 .0 C.
�,
- ) C7 n!
(_
IV 'i:
ll.r 1 Ill
- t : --- t; ()
) L7 q1 .:. S
I'." i:} • 1 U (!1 •iU Ilj
U
`JIl K
i�
J
(l
att ul1,
(il,;� �i go ris:�"
tip
in
:• ,
�,_
to
4.1ijl-)C07nn
}
f)
Orift
W tyJ C1 •_,
, _ t • -•--
Citj
�'•�.n.}U
L;
I:
tom_
[ of r
_
U fit
Isl •...
to
kl i
tJ .!!! l} C7 ''-
77. rtl r�
1.'
n
C) lJ Ill
('
r
[ :
U r
1A Ill 1- r (11
u
41) 0 C,
.. T tU U
Iu
to O ,. L
..,
ili
40— In Il! v ` it)
Q CJ.
_�C
St1 It) ul
Lii'17
li)
fU , 7;5 Itil)c-)
-T1 IU
ru
L7
>
[ C cO
t,1y"Fl .11
1 ;
i it
nJ 4 -3A X] ' '
ru
rsl ' fii
L
vl .; +•
Ill ut 10 -a
o[�
C1'.`n r[I (J
tip
IU
(l) 0 r_
1N)
C7
bi1�
{U
1, 1JU L-
L: tU
141 - a
lJ
CJ � .-' '" <j ,tlJ
�j
fj •V .t� !ti
vi
lit
-C) to
IL) 1_ _0 I11 -.n (1)
M
'O ".: 1-L. C_
M,
�� tw
tit III
Bf7 rU
Q 111
f, ,0
.� �.
- o
rU
l) 1)
nI
it)
1 I
-
I�
lJ' t1,
I rU
-(is hp
ll) IU
A : , f-
,n O
! ru
U t]►
n)
trtl .., =
-
_
_n
L� -
rn
{il "III
S; t: •-;
flr rs1 !.
1
L- vl
L)
lit u
ul
�}ul'ii
1
vj L:
in
a)
Ltj tot/ �tY
�I! Lih 'll
.'
(� lu t11
•iti no nl
q

I—
I tj
LII C r
L-1 0
D
O () , " -
UII
rlr 0.
,U c: U
1:Ir, LW IIJ
0 LI
i.7
it! III
vt
rej
> fu (16 1,
Wo % fQ
ILI
fu
t3 A:
nj (%I >
got (P
Q
13
to
(1) to
dW . 6,
o U
cu n
-C, E] 4j .0-
C)
C: C:
q)
C, 0 aj
G U
() 101
otj C:
l 41
aii qu U
iu IIJ c
E
L:
(IJ
bQ
0
0
t
C i7 Q)
U Aj
its (U
in DD Ul
Qj > r-
X-
-rj CA
0
- 0 at
73 lin Ltj - !!J U.
4t
lu ", -
j IIJ I-
(v
0 m
w >--E
Li va A >
ai L%C --
IS 4U
0 Vi 01 L)is
n
Li, Ln
qJ q)
o 1i CX IV
:j
IIJ
kA -ftu
C-j
T:)
a, 4w ii
(I
17)
cz- c
Q)
Cl) kW-Q
0 C- RI 0-0
an 0 QJC C:
I "i tj
its t,)
0 rU
EV
Ln
r6
Ln-
_j
RI
itii
04
Ili
cl
tll
aj
cl
0
0
L-
al
J
L J
(7
Ct
tj
40
(It
too
v 411 in
o 'S Q) C) >
(U E
-U
Ql
J-1
Up
CL C:
Id
vi .4n (1, :3
16- in
Ub
C'
o
IV)
1W
Ito 114 -.3
.05
op
fits
At
f)L - - :3 0
F I- C)
III-3
E W
0
D" f17 Of) Cl.
0
CU
L c
U in ItlUi

v,
t+u
I—
J
(II
W)C
7
at U
tla�-)
t+to
ru
!�
w
CIL (-►
tU
.� �• I.,
tits
VPq
- tl) W
L] d1
f o
� h
till 4
{)
tU iu
,n
CZ us
[- "
3 I.
C. t0
at
UO.�
, 11 tit
«
[V
u; L�
0 . ,;
t:
,
1 •
M lit
1
tv
ra
at c
tU
+tt
+-
ru — (]
r
01)
.'s
1�
}
It I'u '
bri
la)U bn A: cu c to �)
t'II
O -�till 41 top
• i�
-•- t-�. ,.l .- ' -: Cf •� �� - #- � Let, �. •i�•
_i n_
WI i�: Inv1 l!1 ,I} tl+ Sll ytl �7 S: .. O L• (.) V [ll
N `J ILJ
0O(1 +n >
,. l) rn [ r• S` {) -[) tV U _ tytl
C
t . n `' tl, Itl • -' {i. , Cl t , [l
I. I at u, of Itt .r [P W - •Ij (' O u, i;� +II {{
rtJ ,J
��1.:} _C{-i• -_- 1 «C'. .:1.� iCn] In ) II
-L] 41 (v j _
-1r1 (l) .1-� '!12
tit) ' t1::a -U•_I-r
tj
a Ct _ tl+ U tii ll „ W r 4) t= ft+ i^ f tls �_. N r..
a, Wt 6.1 ,n U [. r). �1 « «I
rU �' IV tll Cw 1l• 'lt - r[t > .. .� tip
[' i Ct ._ t (� t] f) Ali vi N C) `} tv a) (J' off q,
i� ;'•>{ _t�.t%o : •tU `II Qn� itl '�a'll tU a.. �� rlt 1• ::1
tU
Ill i (tl V nl l� ttl • (tt �} • • av
..t) a) ,., cl -' -t� nr 'u ►_ _(- i:. U us » � ,, u1 nt
cu Ili C7 _ �' ru
iU na itf C in n Al C�'Y U .t� j �• t=l q1 `J 1 �N tip till
d, _ t. > �i _ itu ._
N ITt ,n U [il jj �n lT1 D V, +, -C) S: ,,, 11' ((," bl) -- pt
Jl ' rtf C j:: .6 �- .. ` Cl'i_ Z) C� iq [1F Cl. t) c':
'n a (L, L. j ,1. -1 ��' ,ci `n
(::: {_ 1(! '9�•+1 f,) in 'li "tU(11 t) tip l.l_. tit)4f)
}
_(U ;ruu t) tt
41
[1 L) tvl',�` Il) .1-:+'' till.`_ 'V .t.J •i.j
_a L. _t_u U' �` rr s+ r, IU 'n + ,..- : ' �a �'
L.
fJ (it (1) tit +- .G , ,n tV !7 — C1 S J. tU CJ
lilJ,_- t .{. ll �'{ . n.4� C� ri7 IN) • ;.i' ll �tf Fn ill h)O ,
,tit 4 ? ' ! I r1J'tlI hq t' C - .. L1 ! fit _C1
�._ ill -{"J n1 gib [t1 _� 4 �! t �II� �U ;v {V ) U f: [ :�!
(ti [) i0 . tni �' >U t� Af .l: QJ (to f.: f) 1i • i [U C� iii - tit
( 1
U o.

:L
`.1
I
C�
qi I.i
L�. w
c)
nl 1-
J.
.ta, l]
lu �'
it
f7- >.
[L 'n
C} t:
_t ; p
Q ..-..
,U nl
Ir
Irk
[+11
-[3 N
•�� n1
U '-
tti► lJ
ro .Il
It! 410
C 1 tir! sU
[t1 +V CJ
Ely _ r�
w) '-
. � un
� r7
p t_
c Cl. n
•� _i 1-
._ � 1U
ritLJ W
N00.L_ (.J
"In
_' f:
... to ,
rll C7
�' 11u •+� it)
C:
uh �• of
I>;1 •� fV
o -�} in �} a
EIJ lit
b t)
[_
L ul r
>a)[
un i) .N
rti.;= C3 O 't3
• �— ,tt as 1-
p un 1:1,0C� C 1 IU
t D 73 ;v
U
- N'''-
�u _IV
a''t.] •N � ttl
nt [ its au ._
Eu It) [J
b11 `--
h
ja tt3 h w�
C� •?
I. j.
al ��
RE ,u
n.
1A
.Z) [� t►q C) �u
rV aJ ,4- C•J r U
�u tut It.-) :._ nt
rti cv �� to (�
C V In N
,n
U1.1 S,l. r
,n
Cl_
] Ql to v+
in iii Q) p C 1
(u
L-
ur c) -1� CI
N hll'11 L 5
U +U LY
,ti. nJ
3 7 41 tU n[
a:
ru
t1 U
_ N
cl
•� � -� El1 r(�t
W >> > iv
M ,it t_ 413
>
0 In
VI L: >. rlr
tt1 „ -L) tr
-C3 as
nI n ,- , .
uu �"
fL U G; ill
ILI
0 'r y
�J
i)
U: iy3 „11
UII f: I.: ,tf
,U fli f) cI� C�
ni QI t,ry �
tj
in
> Q tU cif
(l INt'U . • rt1
+u
o ur m ;1
q1 •., t1J tV tU
' Lit tit
ru
iv
(11 hj r 00
ai
ES? :U
>• ttl
I.J ' '.: =1 ...
[ 3. t7. 1- +u no
tit
3 U1) C� rU <.: -
>.
., ca 'u C
Ut1 [l; ct Eli
tit
in Ll. 41 l�
tg) tU "o10
[ U
C11 r•: ''_' _.I
•_ U r1) Q1
a..
c ...
_r q
C
C) r! Q +
iv O Ili ", >
1= C tj r
,> rlllip
Cl a
Q •aM +,
t[, _ to ' y
tj
CI
t ,u
t
a
U C- ` i
CI r 1 rll a, 0 }
tit QJ � " rt!
v
cU a(11
ra4JC)hJ
A.-�[. �.
w
_[I fit C) Ul
u rat
C) tl, ii ru
i_ ,_ ... rU
C! tih
,t, "U f7 .0
oytu��.1
>." ai C
Ej In _0 Q1 ,i d
sV} �+ Elt _j rt1 tst!
c CJ
0 N
`•- tt} tV C7 iy
Up�!i r: 0)
•�
U7 U1 ,n
p fY l >75
10
un
U [_ .Tj
�n
3 J I lit
vt tt1 Ul %n
.r:
l)
.n
u CJ
t_ +a
l:l, U,to ._.
c1! +ly
x-
it
i 't}
Il: rp
' L-
ici k7
r
G -Cj
C
U ON
f 7 -C:
tt7 ';1
• ut
rr S1 d
[J O RII
L: C1 Gi
clt
— v, • d
tU C"
Zi
1{rr.CJ U
'1_3 __. C
1 -t C)
tit u
n {�
U aQ vur
Aj
411) t J
:0
_3
[� )C C)
}-•klr V

In
, IJ
;L+ ur � t� '-• ;, 1 � ,11 � •
,n IeI n1 1 1 rYf ttl ( !
I_ •�, (7 11+ [�: 1"3 - (II IU
ir•• 1l Ci jl— I: W } tr Itf �411 In ♦., fr: •��, ;� _l: f) ._. �l) CT +C: [ll } tir : '[3 "1.s
1 • nl _1 L') L? Itr ( i7 _ fu t II i:i r fit tl nl �:_ .I::, Itl try ,it
tot) C iti C'). 0 t1lk rU :: , � lEl Url L} � lr(l
All u IU II1 r1t C:
—'
L:r... .t= — • ql AF j , [J .7 (l J •� _�; .Ll 1, IV uI ) ']:.... t:
UI `� �IJ S _ f• R1
(,1 (.= C: ` - �, `- S'• Ilk - (u I
l L %-' . f •4 .. -t♦ . ..: - -
n •1.1 vt ... (1 •(� !tf [.. (_ [3 ld!
rU Ili - uu J '' ; . C7 ... _ {• �] -:�
L"1 .1 (I C) tll IU Itf t.' u, _0
o is lu! (, `7 `- r.] +U [,II rl) t- �Iii •Q 11 P-> ll r li It.
[. ik) L. K rU- • r. .. t7. ItF 1� - '''- r r i,r, tJ tit {-
41 - VI tll IV 1 j
fU 4 In ;I; qs $ In II1
C.] u+ Ilt f� Ili q1 Il' ItI .f_ H1 lJ `f� I_ ]I C� � •v + Iu [Irl
a.. .. �: _._ a l,U • at Lt {,- [. Ul IC L
`ice ISF [1 LT•,. a;i: Ci jj--
rl. lit. -. :>l _ t ,_J •_ _ C- f 1
"✓ l 1.: -I. <` [ `; III tlJ ";f C) 1_ i Ill [.... L r}1
t@ 1".. t`
t : ill r') -'t.) 7, }_ - , it In ry 1 , 1
rt1 It n .[- ,r1 IE: G .. }' U „1 Iti Ili {,1'
In•l �. tII .,.�[ fl r.) U III I'L tit_.
t•lk _ N f(i uk (U ;lf t
Itl
11• ril 1� .[_
- Itl
•^ t 1 � '-- �i4t ' -> L' k
•�,�CIF .[1 l) t1 L) •" Itl J rU [.! tity L!
� J ,., IU {U .If N [• C1 t1 C) „I C f lit l is
.. t _•� •-• �} ill .L�] [1 l7 "i _ •_ I: S� -- I,Ek C 1 -�. list
Ito [ tit r11 i
`-]•� f7 L1 C: - '- ut . -[-� 1 . [_ �tFf [) -! „f . j. l : { f iN ["
L1 � ttl -• ill Uil t.) IU ,- - •' _
II) C1. +U {: (t i
ttl t•:. - �1T l': f� - It! :n . (: 'v r . �11 I, •q
1 ll, -
t)11 rV .. Ilb •n [IJ In �._ lh <ll Il] till C1 -... i•: iV .. It! •: rl,
I. IF �U { I;� rtf 1': [: ot11), -1} ") !: L: C_ IV C,I l)
131 jU I) ql hl+ttl i7 fl1 ..i __.' U 1 CJ [.Y f 111
ti)1.t_ nl l_ iil t+ ;: s ... +W lu rll E_ IU ili t_ }u_I 1' ��
lt1 Cl 1
fU l,[I j C — •., �� 11) •• _I IJ l f t) C
U vJ I J �'t . 1 vV IJ `� : ;!� idr Ili rti lr1 Alf C" I ,n 111 Lj - []f [ . L 1 [ + . , Ilh
1 r: (� (� I :. 'lJ WI
[ .
i_ S.
_ t.] •-- ', Cl (U I_ {.f ,ij
.f
C} v1 ,._ Itl _ 1 (7 I-: UI 1.1 �! . . V •111 '1) _ l.1
C• , IV [y
iI+ Z.l U+ •� • , ■ . J) -�
"ii C7 }- 1+1] �t.. -C•} Q� U1 Il)' ._• "L7 i,j �1 C] l'•• ftl•� C"l ",1 in tj
hl] ;.: fu [ tlli ['1.'r it)
I fU r _. 'i: I)II
[ •tU CS �_ (: tt1 (� C `.. ru [1 C �} _C) W lU E.: (U f).'lJ L) ,1j �' �l'[y :11.1 - - rU
q-j"! l7 dl •.. - (� •: _ -17 l,fY. - ,.I /•�. (- •:n to �•• [: bfl �J `�! [j It! t ., R.
,7 •_.�N — ��. ,_..— }_ l' 1 • .� - ,tl iJF It) +m tit. f v1 (lJ {:_ v1-73 -- C) rU C) Y.: f1 tF fl r'; l.l. '
�` �:• _] Ill C [) CJ C]. . ClQi I� iS1 .n .I, Ij : a_ �.-Itl O t1F} C) (: C^'[1IU [J lJ [1 tl1 !1
1] t_ ttf U•Ci •- IF+. . (.)...� L. - U1 1
�s IIl ._ 1 '[) �! lZ.•... C r r .(: [7 Itl [) [:.l f .a: lu) ;ii t• r
v1 ■_ IIl C+ - [� -- I'-
IU -1_f ❑f+ C) t: 1) :] C ,V •. E..!-f Ih �lj Vl OFl a-
Ij
nt'C1 qJ I-7 _ rn E] .0 l:]• p - E: •— _c. iJ ,r1 -J '1:1 nn` - _. L R:..-
[.J' I) �- - E!1 UJ I'1 tl Ill
�r'Cl Eli _� .'I rk_ _ Ll UI :_ . .r C1 �_ - IV f 1`_'�f L"]. •I; _il:.._ v, 1 (' ;1J
.� t- Ill • N •tit) �� t_ t� •=f L Si
ciE LZ Tj—r. ra ••_CL__nlln
�r1 tuJ
a1) .�_ p :: t _] c_ (' - • t' 1 r�Y t Ir, .11 r •. i,il=• .l
to
c)
VJ ll v. r.) ft1 •` i,]7 rh I! ilk t� - •1 )
[� '1 t}j U 111 jam- Iu iv 11 •� �' 1t! till 7 [tI

its
us
tj Vf
••
Y.
(�'
-'J
k.l ,tt • 7'
�'.
till 0
1 'ltt
rk
I
1,
to (1
to
t a
of
rls [.
hIl i, 1. 'C]
r•].
)
Is
Is
r,
lJ t) i i Jl
�;n {1l
!11
U:
t]t [U
IV
tJ 0
hP iJ C].
l
S-
1•i
1.1
v' -]
rU
ld: t • j
IS} .. ;1
✓�
rll
ll,
�'� t[1
'C7 Ql •.
Gn
_r: ,1, lr
s•• � nn
"!
a
r'; i-
-lu nl
".
--
Ill-ta VI
_.� Ill
1.7-
�,.
•n
bil
tj
a C- .,
An .' 11,
.n� {SI
�� tdi
•� ['
In vi
Iu
U)U 0

WASTE UTILIZATION PLAN
Dogwood Farms
Wednesday, October 14, 1998� 4
Producer: ©. K Spell 154�SC�0'PeVW�
Farm Name: spell wog Farm
2420 Five Bridge Rd.
CrLntm,NC 28328
Telephone # : [phone]
Type of Operation : Feeder to Finish Swine
Number of Animals : 1240 hogs design capacity
Application Method: imgation
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface and/or groundwater. The plant nutrients in the animal waste should be
used to reduce the amount of commercial fertilizer required for the crops in the Fields where
waste is to be applied. This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil tests are strongly
encouraged so that all plant nutrients can be balanced for realistic yields of the crop to be
grown.
Several factors are important in implementing your waste utilization plan in order to
maximize the fertilizer value of the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the needs of the crop to be
grown and the nutrient contents of the waste. Do not apply more nitrogen than the crop
can utilize. Soil types are important as they have different infiltration rates, leaching
potentials, cation exchange capacities, and avaialable water holding capacities. Normally
waste shall not be applied to land eroding at greater than 5 tons per acre per year. With
special pre -cautions, waste may be applied to land eroding at up to 10 tons per acre per
year_ Do not apply waste on saturated soils, when it is raining, or when the surface is frozen_
Either of these conditions may result in runoff to surface waters which is not allowed under
DEM regulations. Wind conditions should also be considered to avoid drift and downwind
odor problems. To maximize the value of the nutrients for crop production and to reduce the
potential for pollution, the waste should be applied to a growing crop or applied to bare
ground not more than 30 days prior to planting. Injecting the waste or disking will conserve
nutrients and reduce odor problems. This plan is based on waste application through
irrigation for this is the manner in which you have chosen to apply your waste_ If you choose
to inject the waste in the future, you need to revise this plan. Nutrient levels for injecting
waste and irrigating waste are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. Acreage requirements should be based on the waste analysis report
from your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for ananlysis. This waste
utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
21-1.0217 adopted by the Environmental Management Commission.
Page 1 of 9

AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
1240 hogs X 1.9 tons wastelhogslyear = 2356 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
1240 hogs X 2-3 lbs PAN/hogs/year = 2852 PAN/year
Applying the above amount of waste is a big job. You should plan time and have
appropriate equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on the crop to be grown,
soil type and suface application.
TABLE 1 : ACRES OWNED BY PRODUCER
TRACT FIELD SOIL TYPE &CLASS- CROP YIELD LBS AW COMM ACRES L13S AW APPLIC.
DETERMINING PHASE CODE NIACRE NIACRE USED 71ME
9846
1
WAGRAM 0-5% BP
4.1
205 9
1845
MAR W
9846
_ 1
WAGRAM 0-6% 5G
1
75 01 9
675
-9L
9846
2
IWAG RAM 0-6% BP
4.1
205 4� 1.5
307.5
A;5 RR-- I
9846
- 2
WAGRAM 0-6% SG
1
751
112.5
SEP-ft11f OC;
WrALS: 2940
�Lf
- Indicates that this field is being overseeded (i.e. interplanted) or winter annuals follow f
summer annuals.(
' Indicates a Crop Rotation
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N
requirments. Beginning in 1995 the Coastal Zone Management Act will require farmers in
some eastern counties of NC to have a nutrient management plan that addresses all
nutrients. This plan only addresses Nitrogen.
Page 2 of 9

TABLE 2 : ACRES WITH AGREEMENT OR LONG TERM LEAS
(Agreement with adjacent landowners must be attached-)
(Required only if operator does not own adequate land. See required specifications 2-)
There are no Acres Leased
Indicates that this field is being overseeded (i.e. interplanted) or winter annuals follow
summer annuals.
Indicates a Crop Rotation
" Acreage figures may exceed total acreage in field due to overseeding.
"Lbs AW N (animal waste nitrogen) equals total required nitrogen less any commercial
nitrogen (COMM N) supplied.
The following legend explains the crop codes used in TABLES 1 and 2 above:
CROP CODE CROP UNITS LBS NAINIT
�BP
HYBRID BERMUDAGRASS-PASTURE
TONS
50
5G
SMALL GRAIN OVERSEEDED
AC
50
Page 3 of 9

TOTALS FROM TABLES 9 AND
ACRES LBS AW
N USED
TABLE 1 70. 2,9401
TOTALS. i0.5 2,94U
AMOUNT OF N PRODUCED: 2,852
—BALANCE -a8
"" This number must be less than or equal to 0 in order to fully utilize the animal waste
N produced.
Acres show in each of the proceeding tables are considered to be the usable acres
excluding required buffers, filter strips along ditches, odd areas unable to be irrigated, and
perimeter areas not receiving full application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than the acres shown in the
tables.
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of
sludge at agronomic rates. The sludge will be nurturient rich and will require precautionary
measures to prevent over application of nutrients or other elements. Your production facility
will produce approximately 458.8 pounds of plant available nitrogen (PAN) per year in the
sludge that will need to be removed on a periodic basis. This figure is PAN when
broadcasting the sludge. Please be aware that additional acres of land, as well special
equipment, may be needed when you remove this sludge.
See the attached map showing the fields to be used for the utilization of waste water
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the soil at the time of
irrigation such that runoff or ponding occurs. This rate is limited by initial soil moisture
content, soil structure, soil texture, water droplet size, and organic solids. The application
amount should not exceed the available water holding capacity of the soil at the time of
irrigation nor should the plant available nitrogen applied exceed the nitrogen needs of the
crop.
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every 5.92 months. In no instance should the volume
of waste being stored in your structure be within 1.7 feet of the top of the dike.
If surface irrigation is the method of land application for this plan, it is the responsiblity of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in Tables 1 and 2. Failure to apply the recommended rates and
amounts of Nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application rates and amounts.
APPLICATION APPLICATION
TRACT FIELD SOIL TYPE CROP RATE finlhr) AMT (inches)
9846 ry1. 22 WAGRAM 0-696
' This is the maximum application amount allowed for the soil assuming the amount of
nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Page 4 of 9

PLANS & SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited. Illegal discharges are subject
to assessment of civil penalties of $10,000 per day by the Division of Water Quality for
every day the discharge continues.
Z. The Field Office must have documentation in the design folder that the producer either
owns or has long term access to adequate land to properly dispose of waste. If the producer
does not own adequate land to properly dispose of waste, he shall provide NRCS with a
copy of a written agreement with a landowner who is within a reasonable proximity, allowing
him/her the use of the land for waste application for the life expectancy of the production
facility. It is the responsibility of the owner of the facility to secure an update of the Waste
Utilization Plan when there is a change in the operation, increase in the number of animals,
method of utilization, or available land_
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for realistic
crop yields based on soil type, available moisture, historical data, climate conditions, and
level of management, unless there are regulations that restrict the rate of application for
other nutrients.
4. Animal waste may be applied to land that has a Resource Management System (RMS) or
an Alternative Conservation System (ACS). 1f an ACS is used the soil loss shall be no
greater than 10 tons per acre per year and appropriate filter strips will be used where runoff
leaves the field. These filter strips will be in addition to "Buffers" required by DEM. (See
FOTG Stantard 393 - Filter Strips and Standard 390 Interim Riparian Forest Buffers).
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil
incorporated on conventionally tilled cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application does not occur during a
season prone to flooding. (See "Weather and Climate in North Carolina" in the NRCS
Technical Reference - Environment file for guidance.)
'7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
runoff does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control conditions
conducive to odor or flies and to provide uniformity of application.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with
a high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste shall
not be applied more than 30 days prior to planting of a crop on bare soil.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following:
the outer perimeter of the land area onto which waste is applied from a lagoon that is a
Page 6 of 9

component of a swine farm shall be at least 50 feet from any residential property boundary
and from any perennial stream or river (other that an irrigation ditch or canal. Animal waste
other than swine waste from facilities sited on or after October 1, 1995), shall not be applied
closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal Waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landownwer.
14. Waste shall be applied in a manner not to reach other property and public right - of ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted croplands
provided they have been approved as a land application site by a "technical specialist'.
Animal waste should not be applied on grassed waterways that discharge directly into water
courses, except when applied at agronomic rates and the application causes no runoff or
drift from the site.
*16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc.,
shall not be discharged into the animal waste management system.
*17. A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). If needed, special vegetation shall be
provided for these areas and shall be fenced, as necessary, to protect the vegetation.
Vegetation such as trees, shrubs, and other woody species, etc_ are limited to areas where
considered appropriate. Lagoon areas should be kept mowed and accessible. Lagoon
berms and structures should be inspected regularly for evidence of erosion, leakage or
discharge.
`18. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
*19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks, and spills. A regular maintenance checklist should be
kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops for
direct human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied as a preemergence with no other applications of
animal waste during the crop season.
*21. Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to mark
the maximum storage volume fpr waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least
annually at crop sites where waste products are applied. Nitrogen shall be the rate -
determining element. Zinc and copper levels in the soils shall be monitored and alternative
crop sites shall be used when these metals approach excessive levels. pH shall be adjusted
for optimum crop production amd maintained. Soil and waste analysis records shall be kept
Page 7 of 9

for five (5) years. Poultry dry waste -application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina Department of
Agriculture regulations.
" Liquid Systems
Page 8 of 9

NAME OF FARM: Spell Hog Farth
OWNER / MANAGER AGREEMENT
I (we) understand and will follow and implement the specifications and the operation and
maintenance precedures estalished in the approved animal waste utilization plan for the
farm named above. I (we) know that any expansion to the existing design capacity of the
waste treatment and/or storage system or construction of new facilities will require a new
utilization plan and a new certification to be submitted to DEM before the new animals are
stocked.
I (we) understand that I must own or have acres to equipment, primarily irrigation
equipment, to land apply the animal waste described in this waste utilization plan. This
equipment must be available at the appropriate pumping time such that no discharge occurs
from the lagoon in a 25-year 1-day storm event. i also certify that the waste will be applied
on the land according to this plan at the appropriate times and at rates that no runoff occurs.
NAME OF FACILITY OWNER: A K. Spell
SIGNATURE: DATE:
NAME OF MANAGER (if drrent rom owner):
please print
SIGNATURE: DATE:
NAME OF TECHNICAL SPECIALIST: Bryan Spell
AFFILIATION: Dogwood Farms, Inc.
ADDRESS (AGENCY): P.O. Box 49
Clinton, NC 283290049
�--7 (910)/592-2104
SIGNATURE A9 DATE: 1 C2
Page 9 of 9

_ - �� ,�� '.' ` � '-j 5 v� %c'� � 4;1` t ie' `�' + �fi ,.f,�v P.•x r "Y3- ., , `'�.: ;irti . _
�• f )z F ;;,1' ,, ,5.,1 � f9 L' r '•� ,�( t- '� I,�,,;•Y'r 1 _r' 7.�•
`�- f 1 e,yr . 1"�iigk � Y y �,j LF i .q��7r�•*x-'"r �1) .r.I� r °a Y, ,•' '�� 1 •� r•, R•.� • 1• � r ,' P ,i
'�r•Si �,�� �'• y 1 r3 �y''C�.y• ' ��.� f��5��={ � L` yxJl rR,Mk,���5. v:Q � �3r.�`t'� ��t. `L� r�r; S .- L.•- a
�l� ': '^ � It'i+.'ry ,•.,",r��ri, 11ii.`:�'=t K'�y,. ��ff��Qr'r!f` ,,,I,d 'i1,
I�l�r'f'1'J. •• w•'.s I, t ril�\ ' �I� `',��. r.' l�;• �t1Fk„I,a �i. 1•+'' ,t�� •� } j i 1
* �`'�{:�C "' ��:�?r { i F�"yr s rf1,�f `'i"r�L" �S• '� , '`y rL t 'r .
fir' Ir� L�;xt
vr 5 .fLt .2 Jf I? •'�'• L•1 +f'� t�. N r • �,i �.S47i
Vr-
FJ
r ,, rl w.i a °°•rt..S ,• y .
t�ai' "',Lr�' jd {lyj . •i�1�1 '♦,y,j f 1 'r •' .
l�� �r• � :. Cr 1 `5
,. 4 �h(.a jL'j'L`71 .I'I '`f�� 'r + ••r l��,p,3o.• I, y.��,f� • a• '�:, ,
.+J r �V .',,• .. �7� � � �Tit.� i t �, 'r 'L'•"Ui,-.`•, ��,' 1• '�?, -'
- = f4 i'i' re.'v'•`r' S.. .( `I•:: • w "F �"� 't � '1•� ' i,{,r. • 4i�•h { - i t " .. �. ^ � i �`~• 1 � -
- _ - Y _ti 1`.t� + j' -S, �t�?• .`' :�• ,Yea I,'..;1 .i.' ,-i,i� •�!T tr L ^e s, �e.� h: "R;.:.:F �s, - �'•+ _
•r• ( 'i .f'PiI:: � r +• . •'L F Y n,i �=i� ftt SSA} `°�� ]''iF 1,'.tti \• R S+'''y ,•t.
•-`Ix.?`s,.itir: 7 ry,�i`�.�r� f' '. .'1 r:', r,l,�S1"-.. 4f� r1: rir•f-,((a: •'�.�l�l•l�i:ro rl ��.,� 1'a-w Pi ': fir, �'.°•, Y• i.'..,i :•j ••7 �:'.,' .5
f�• r.f'+t- .r ,:r t• �� � 1,.,1 a t>>:�1 i t.k t f- i+j •',tL: •rr '
`" _ '• ,i, ; 4y i , i ', 'll `'i*(,i '!1 F,r r 7r � 4t � � i�l 'Eyr�u� �� •r � � '�4 �•,, •y, / :}....,•t.,r�•„ ��.
S 'S.
i , :Y t• �,,. .Y''ti ..i,' r j �=`§ti't'..� �`k k:•' 7+�y i{ r A �,'n�'y „k' :'' ' 's
'r :t•' rr 3 r f �. �,_ .- i a .5 {-r Ie L `• 'w�r.�44?'sl;�YS+'V'r,,,,� ''�,��� tia?J., 11�i y• r '•,i.'-'r' y r 1•: t!,,, ' +
•5 ,' M1' 1 ..t• wrf. •1 f' .i. 14'.,�- {� .YAl
L--
1 i}- lY;� � � L, .r !�1 , T y:,;•,�r ':.:^.'fir + :y
LL
� .`_ Fi. � ��. •' +,3 � t. 1}. �9 � n�l••xet�C i,'A•��k• �'r �Mt �'�'x„ t L:• b�a�5 !'L
i ;4't\'� f r ;:# ��J'^i.t � a}'l�i: tl.1a Yt -a`Jrj w; a+^ •t�') 't
• '. .+ � • r �� hh i �3 ry{ � tt' • ' � .c :,• �!� i'� �y 'Sr ilr r
�' - �1 � t.."' .. t�, `\7' f ,+�Y i'-�i �Y! �.•y(_iit.-"�t.�,.. r ,R, �1
• � 4 't �s.i'7' 1'� }aT •�.*'i lt�,�,t:rr d '. ��il 51 ._,F - :1 i,'+.
1 4t t_

.- E°
EMERGENCY ACTION
a, k;
7SYSITNI
SWCD 910 -5-92-7963
NRCS _ (9Z 0) 592-7963_
l i�S �laii '�'i� oe Ii..DiC_:iC^L=� II'. ti':C CYC:1L LFI?r 'x'`SteS LOIi1 �'GtI,; CL:C �L'CQ ZrC i8'�ti:'I_tr.
ovemowing. Cr r-lanlrls Cr: Site. You si30ilitl not wa:t unul wast:$ reach surface ware:� or
leave vour o rcreny to consider L':ai VCu t;aVC a DroLle-m- You S:-ICtid. ival{= ever; io
ensurC that ts':t5 CCCS nQt M1=T ' ' -' Ln ?'I aCCC4siiale ICCaticn for
t.,e i ins �iaa s.;o+.i� �t ;.as
Id....:;ctC.....5 at lie fC:1l:f. 1.:.. rCllCw.._ are s+..a::C a Gn tt..,.:5 VCti so...d c.,4 .
i. <<c4 die rcicasC of wastcs. DepcndL--la Cn the si:uaticn, :tins mnav CT u:"'': CC D-
Doss.biC. Suzses:ed nspons--S�to sole YC5si Ic p1mbf..`.:S ZC ilsted I•elow.
A. Laecon ove, low-ressicie solutions am
a. soIl CO E*e.a:: to Inc. -case !?_vation of da..•_:.
C. PL':?Ip waszes LQ 7ie!d.s at an acz--pt :Ole ace.
c. SGco a]]I r!cvvs ICE :i z iascci! i"m tiedia, teiv.
d. Cali a pumping connctar.
e. N1ak. S irz n0 s:==:aCe W=-Z - is e^te... o canon.
E: Runoff from waste ancEc=;ion field-ac:iOns Lnc:uce:
a_ I:—nmediarei 1 stL1 w ,z= apcikaticn.
a_ C:-:!Le a :=ccrari crve.sicn to
C. I nck-dr` orai.- was:-- to . "-C-0 ;ailCii.
G. Evaluate znd e:i mare the ieaSut:(5) z2hat causcd zhe :'.:noff
e. Evaluate the autnicarion Pros for the t'ie:Cs ,V e:.
C: T Lzze .r+:%1 the � 1-e5 u:C ]t;r:i3:ti..e:s-aC:iCC: Ii":C
C. cco rev.-C! �a:;.0
C- Closu �'=t'.'CS i4e�i:c:...,.E:.`'.:%:'•C.' GiS.=:,G ��.
C. Ce" i; at3 fe=.tis : iGi co
C 'I�hlf=L1 •'G��:_._. �: _�:�+. _���. LJ.
l E4'U

SE
VC
LrA
r3 .D
0
a �
� rl
V C:
1 Al
bpi [;
(4 n1
4) bpi
U rl
rl I�
�v1 N
] b10
U rl
�. bfl
V rn l:
fU AT .t.
a.`'
U
VI
U A� v
V r in
4-•
ti O
.rou
v� iH V
rt1 r� nl
VI
As nT 1-.
al rj 3
V r�
M-U
W
r. .o
N Q
M1l��•i.1.
C1. II C1'
t' M1 I
[_ AJ 4A
i�
r.a

7 ,, , ".. ... I . . . .. .
:;wills: Farm VVl-.;Io managuilmlit Odor Goldr(O (AlmAklit.-A
1INI I's Ila IN I ill hill 41. till v
.IIImIC;lll161114111clilm Vigonlivu iir w(imled 111111o.r.;
Q�111 mullipill.-Illiell bust rirlllll
illillplicill and (.0111111till ICIM,
Aitimal Ilostly mil hices • Dilly III-11111le-clivoull 41111111.11S _J)I-y Hilms
$tell %Ill I-141C,14 Wo
- 1 1 1A.1111:15 Ill 161-.11 1-11A Ill' %illill Illmist
I/Ifilill-Illmll vcIlliladim fill
.111111C CulliAlillit 11115 Pr i-,I aullacill Ill 11111111'. 1 cill 11VA 19 1 ItIAT, 1,;l 0 vq lull
11111001 Mll I..IL%:S blAwn'ti
dulively alinvivillmil uOullilt-vi ill
Agilatimi lif I Ct:yLlk:fl 1-31',1111111
fi-Iiiial tivilile lailks my 1�'.11-rXICIIII fill lines, ill 11101141111 (d' it fill
till vc111%
i'l 1-1-11-4-11-1 1-: 4-1 -11-1 V-1 i-1 I -i L-I I i -11-1, 1—
I'll ic% 11.111-,C 1111i1its 0 Al%il;sliem id'sceycled hl-.mm ExIcold luchlill"t. lilles, lit 11cm 1119111till ill' ljll�
lisplill Mlile pill life fillisilf, 11Y,14- W11111 Imli-siIIIIIIII vcIlls
fill f1,111�1I11 a A ghalWov olin hop, sismis lic
I joilliols: diahi uilluctism • A gilatimt ilm hor, livasimidef l:l)Vq7I!I
fit pula;iPpo blixes 1:011VIOTMILU

p I
M
_ .r - - ...�.....a.a.•�+�.. a
— 5nl+rep
a....r+.•.a•.aw1...wr-..rr.r.....a.a.....wti..wv.....a.a...--...�
_, _... .. .�.-.
Cillise —' il'All': low R1111111 fl. 11 elfol' .........
Sill..+..! • - .
_ .;ilr. ,, u•[ llir !`1 itl oil rr
^
1;11il llrlllailllliprs ;!(
•'
Al;ilinlitll{ i11 big 1 aslemocr
,� — _._4
(.�' I;x!['{{l� 11;sr11111(;is 11111111 tt( IV.1livall l
liil uun
clinveyalux.
1111mill 111111111 level .
1.410481111 sill facts
•
Villatile gill I:illissittllt;
I,,,iI"I IiIIL'1 lul;llifl{ Ilrllli[i 1'lll"Ht;lly';
•
11illlogical{Iliximil.;
�'1 � ii1ect lagi11111 Slill11111 ill ocI:11111cq
•
jil;illllilslt
%inillmill s1111,11ce ill ell, (ii•vn11111 , Inlilt;
.
{I1i11111111 ill;Ili11i1111 1Y111:11 1H1111141411;;
P7 i�telal;,llic;1111cliliinll; -
(I I'tuw!u (linlnl;ielll rtrhli{ivrc
Illi J11411t � 11114LiCr
1:' 1
•
11 4Ii11iU11'
1, I I'
.^ . ..~—..____ .. ,....... .... .
Irl 1, y ? vilitl,
INILi1�5
�I�In4l 111itllnc
t •
�'l" i I11}Itillll t tl:ll:nlll1114'EN1C11 Ito+� 1111it+111
i I
Pr 1'lllllh illlil(:1, local SIII lacc;
('1 I'suult (iuln st:cnnll-1;1a1;r. li+I;utnl
:iirri.r(,c lalll. lit krill
•
I'at{i111 illi+rilhi:t) tll nitllulsifinit;
I;I 1lvliu111 lit, ulillll.vcl 14t:111ti111;;
"itla[.[s
4
Mixiltr, While lillilo(;;
C. ( �l i1111; CitVta �;
•
1
Aghallllll where C111111y1111;
CI I1i1S111 till lime, inak Ill sill ilk;
I.l I'111Vi:l1 Ilil11411;ica41 114111ilivcs. 411 4rk ilhillS
:![Illllll� Ifinlll . ilylliti4
•
('alliit(Ini�etll,ial tool nlilltnvili+rn;
t.t I;xJ[ 111 11111l111+1111; F11il1t:l:i Illitllll llt;lllll I111011
•
Mixing %v(lile tilling;
.• -
•
At,lliill4}II tYllen tallltlyin(,
I�1 11l'111FIVC sClllcfl ti[ilill.'i irt;Rlall)'
ti1.inlnc slue Ir1 shl+1 ��.
Y
!� tu! %vIicii S rlCllr(111 I L.
.11 1 in,i+:clittll ufslrnlylsl1t11t;r.s;
•
s144[,141c1 uufl4 s
V411.1tilts kits cmissillitx
Icsillintl tlritlitic lil+lll r:Irlrnha allrtl 1t!ir;
(- I'111V1.'ll ltlllllll;ll:lll i11111111V1'S oil limit t1111'.
Itimil •[led411111t11t[:,
Vnlillile gal cnlissinhs while
t- ',;'il injeclilm ill' still Iy/011111;cs
sillily fir shlilge toll livill
all Ving.
fit' ;i lit incnllu11111inn tt'illlitl'i!i In.y.;
( 'i 11t1 fit (ililt 11161(nlll Ill)'t'1.'1 toil lapill 411}'1:11�;
I'll Ven IHllllll;ical alillilives m lixill:11113
l l�:[Ii i1tt111t.11S
•
.ill l: is:ii lll'C1111111115111t1t1
(• 1'11111ia 111Slllitilllllli t1I 4::H S:S1:i S1:.'3
13r:.4rl .11tioll.11 ,li.p4r..:+l
Calcass ltccli111(luxltiulI
(I t:41milllslls cilvt!lltil; Ill cal ils,1 , ill 11111 idpil.r';
Igis
(A l`iFtll,:r t4rc:rlt4rrl/r.,ni;Unr.liun Ftl tli aln::41 hill
iul,rora;,lla.
tncuin1114:{is [:,tullru!:linli �
ill :;e[:un+(ury zi:i,'l; (nnln:la
• t I ....... Id".. I 1 141'16. 1',tn,: 'I

'
— — _�" - - --• +- -�� - ,
i1111icc
- - aLl1•:i•••V..r1,.a..wlrlr.ar.r._-Irr:rarN�arr_.•-:.�...
{,IIIISI:
.... -..- ... .. •. ... • __.. .. .. ..._., ._•a ...._. __i . _ _ ,. ...
��i1Y':}trsili,I'1a+iit�ti
11AJ1'as It/ 61111hillrr Ilrllrr---.---••--�._..
t•
..� �•�•
:ititl111111I� IYdlt l .Ilflllllll •'
IIHIUoper oiloinal-,c;
�
-
rT j1111{p illll{ {i111fISrn{IC 1{IIl1 tviltl
11[.I1 l l{1711115
�.
I,ltalillcs .
Miglullil1111CLIIIIIIHISilinll rll•
I11Yily 11011I 1111ali1ic1.
:
III oullic ptplll r
1,I,1ll�lu 11110,t:111ltilu
foully 11111{ul:lillcll licct:ss Ium 1,
C I'Innl Ilcccss Insll ulllilllrn;lrlct�
I1111111t: lU.11ls 1111111 1i11111
r
11OXIS
•-•�_---......y...��..,.ar-a.d_,.ax,.,.t<a.,•rrw_.,i-�,-.z..r�•,i._:.—r—:�_._,-�-.,,,,...—.-„„--..�.-�t-�...��•--:=s-.::-•_:::n
:_�•'_---=-- - -
.�+r,r11u11;1111tGrntlfrli++1l:
.11tillll: hI;111111+: 1+1all:tl;clnclll ; IT•l111T 111IIC/1111•{�' l'it�kl:l
;iNi11C ('iN1111t i1111 VwIII 1'1111:1111ul Odor sllnfcCS will 11c111cllics. ; UIIAI's Faul :iliccl
:;lvinl: lhnsluclilal i 1lcilily (►I�IIIIIII. 1411uugumunl; 111 It1:c;llltigu - I.ugittiv1 '1•rralluclll ; EllAli 1'1.11.114
Nwink: 1'II11111ohill I'ilt:ilily hliflittl .' M1111111,cloclll. 1,11111c1lloot I'{Ilsh - I.u1;r1Un'I•Il:allrsclll ; VIIA H 119.1111
L.,11�11I111 (Tt:sllpf 111111 h1:I11-IJ,t:11lum lilt l.ivuslrICL. MRrlllle'llcnirlil:fll mid !Amy gu ; Ii11Ali 1111-111
l'alillialirrn+rf hlunlltl: 111111 Wamewlstur A1y11il:uliull-IEIJtsiluflcnl ; 1:IIA1: l urt tiht:+:l
I'tulllullilig f 111uts 1111111 NwillC Iluilllilll;s ; 1'111.75
bi iltu111rlculal Assimume IIIIIII1in11 ; I•IP f; Iylinllnll
11111i,tm 1111 Mallogisll; l lllllr ; is lcilull 1•1nnl 1111: Swills: 111111- o5l; 1:411ce.
•' IJimajit; c I'lulcclt+s in Atlinrll Manslfl: ManagililcIll., 1TtllIt!1.11111 FIics , 1'1tl IIII-1, 1911 s 01111CIcm:C PIItl ccIlilll�C
111";ll, i'1nn,lyI{�h „••inn i'rrrfr,
tW.1;11 - IIAV
11r :a1. IIAI:
ItI::.II- I1A1:
111"01 - 11A1?
1 It':;I I - ";rv.iltc FNIcIt-,i„n
111' Poll, I'milm.cv, Avmc
I If 'NI I A1si 4'ttnu11 miraliwi;:
1:1111 1,1 l'1u,Ju•ralivc,, VNII fl•,i,u1

Insect CoWrol Choddist for Animal Operations
NI III u— - - CUl1YC llllll's!n('unUel)liisrcls tiilr.: perilit I'Iarlicrs
--,.,.__ ..... ,.._�_. .. ..._l.itluilltiyslcnls �----_--------- --_.-•__..-------••-•------------•--
_1111I%11 i 11111clS Accullmialiott (if solids Fllish sy5lcut is ticsiplicil and nlicloicil
Slihicielllly Ill lelurlve act:111on1att:ll So11t15 Ililltl
111CIS as ticsil;ncll.
w-i Iteillove bsidginl; ofaccIIIlIIIIal d w1ills at
S I:l I:yrl;t•
Lagotrlis alld NIS • CIlislud Solids IVliili1Iaill lat'llims, SCiili111; Imsills ir11d I111s wilvi c
pee hicediut; is al pamil Ili Ilrinirrrirt: Ills
I'luslity, ol-slrlid. to a IlepOl of ills 111411C Man (i t
'ficlua liver uuwc Man :111';n ol, Sul face.
EXCUSsi►e vegewlivi I ecilyillh vel'-dalion Maillwill VC1"allivC Collhol i1} ing Is111l's of
1'11omill lagoons ilnd 1111le[ Illllllollillrllenls lot ItlevClll
�i-cell Sliblal.p. Acclunnlaliolis ill' Iced ICSitllll:s
Im1111il11alioll (11 (Imlyiili" vel;On ive Illitlicr
along walet's ctll;c olt ill list little llnclll's liclirucicl.
far �1}ry `:yslolls
ksinll. olit:laic alld ulailttllili jecd S}SII:IIiS lt: 1'..
11111 LCIS and llolighsj 111111inimile 111c
tIi::1111rr11illioll tsl IIt;Cilylll�; wasllll;c.
lIcau up Spillage on a rorilirle basis jc.t;., 7 - Ill
di 'u1r.! val 11111 ill), slimmul. I S •:II}clay illicl val
tit ing %vll11R:11.
W 1(viltice imik11ItC acut1111111a11tili within mid
arotnol il1mlet11alC plAilleler trf ICIal Mihaly:
ill uas by Ilvalli1g., Illailiagc away Iloill Sill:
Illld/or 11141viditll; atictin:lle conlaitinu:ni It: 1; ,
ct .14:11 hill for b1cm-l's glaill inul similio hil.,h
IlloitilllllS l;fillli ltiollncls).
1 IIIShcl;l I'm and IClnovc Ili- bleol; rlll ; ct:11111111alLd
solids ill filler s1111t4 alllllnd fta:11 slolilt;C N9
A tt11t' - 11,1,.vvIiiIii I 11. 096, I'd l;+: 1

­-=...:n:^..---.". ys::--_-ass.. ..... .�.:,.. ..._.a....--::..s.:-:. ­:.eL c: ._s.._• W-:­,. ar__--:..._­- a.i
411441'CC h444154 ,,� IIIIII's I4+ f'aitll'oil IINso! as Sill- Slit-vilic 114 avlil'r%
A11ia1al Ilal+ling Aicas Acclllmthlinlls ufanimlll ►vaslc5 I Flimiliale lo%v Yici15 Ilml IIi11111tttistme 4111:nl,------� -- --- - — — - - - - --- ----
111141 feel) tvasl:lge I'Cllccs :ul(I 10111cr 111r:illi4lm w11C1c waslc
Z11111111:Iles will IlislWllallcc I+y allillmlS is
illial.
Maintain (dice 14)ws a1141 liller sit ills alunnd
animal 11111(ling, 111cas Ill 1161 1111/c
accultlttlallolls (1f waslcs (i.e., illspuct Im atul
Icnll)vc 01* Weak fill nccmmilaitil snlills as
1:4Ied)•
{Sly Mi(111111: 11allllli ll; • ALCIIIIIII iI iOl1S IIf ;IIIilI1.I{ %V;lsIcs 11c111.IV. SI1il{:11;e p11;1 Illlllill! IIi4Sls (L'.1;., 7 - I41Y
Syslculs (Illy inlclval (1111in1; sllmntct; 15•311 day illlc1val
4lnling willicl) Miele matlme is Inatic4l lilt I;mll
1ltllcnlinn sit (lispisal.
I'(n ' le I' . a(Icllualc II(aillal,c :+1u11ni1 111:n111Ie
. na11l iIuS.
(A Insllccl i'nt:u tl 1ennlve nr bleak. 1111 acclnnulalc�l
1v;+tiles iIt lihc� shills a4nunJ st4sckl�ilcs:+nrl
urllnn(:ltalldhill;'11CW. it!; 11cc11c(1.
lilt 111111C inl'lnlalinll C41111.1cl Ills (.nllllcullive I:xtellsioll Sul Vice, 0cpatlnlcltl ill Ettlmiminry, 11t1x 761.1, Him Ill I'atnikm `;tale I luk,cl 1y,
A.116811, III', 21,1695.A13.
ANI14: - I Iuvcin1w4 I I, 1996, Viigc 2

1.
IU t
�► ei v�
4r
,'
1
'�� •11
rl
r
1 .
t•1 11
•Vf
.r r ..1 1 :
R1
Y
fij 1•
�fj
•Lr,
��: :1 Af
V 1'
:t 1,
ftl
VI
al li)
lei
1•i
U
41
.I„}
Rl
,t
�;
•f : •t•1 •vi
11*
•ram
� yr
•!=
i>fl it40
+
J
ql
tFrl''�
11
1', (•
'cr
il •; �
'I=i r•r 11.
•lJ•
UI •�+
Ar
�Yrl
RI
•VI
t-'
� I
1 .V
.:
•'1 art
�'
RI f'I
,1
a�I 41
•.�: ^� Al
�'
tJ IJ
+, L.. •�'
cl
My
Y
•-J
rY 11
it .0
t j
t r
�1 r-�
1•► it ...
U
11 tJ •►'
i,r
U
-
'-r
'I 1fi
,
1'I
•t
RI l•1 V a}
•1' •�� � �
'I l
•r 1.
! � i..
A�• r l •11
rljJ, i
t-
.l
7
l-.1
1�1
►'

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Derr T. Stevens, Director
D.K. Spell
Spell Hog Farm
2420 Five Bridge Road
Clinton NC 28328
Dear D.K. Spell:
4IT
•
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NAu- RAL RESOURCES
December 30, 1999 R E C E I V a D
FAYETTEVILLE
nEO. OFFICE
Subject: Fertilizer Application Recordkeeping
Animal Waste Management System
Facility Number 82-427
Sampson County
This letter is being sent to clarify the recordkeeping requirement for Plant Available Nitrogen (PAN)
application on fields that are part of your Certified Animal Waste Management Plan.
In order to show that the agronomic loading rates for the crops being grown are not being exceeded, you
must keep records of all sources of nitrogen that are being added to these sites. This would include nitrogen
from all types of animal waste as well as municipal and industrial sludges/residuals, and commercial fertilizers_
Beginning January 1, 2000, all nitrogen sources applied to land receiving animal waste are required to
be kept on the appropriate recordkeeping forms (i.e. IRR 1, 1RR2, DRY), DRY2, DRY3, SLURI, SLUR2,
SLDI, and SLD2) and maintained in the facility records for review. The Division of Water Quality (DWQ)
compliance inspectors and Division of Soil and Water operation reviewers will review all recordkeeping during
routine inspections. Facilities not documenting all sources of nitrogen application will be subject to an
appropriate enforcement action.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Ms_ Sonya Avant of the
DWQ staff at [phone] ext. 571.
Sincerely,
Kerr T. Stevens, Director
Division of Water Quality
CC'. Fayetteville Regional Office
Sampson County Soil and Water Conservation District
Facility File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity ARrmative Action Employer 50% recycle&10% post -consumer paper