820473_CORRESPONDENCE_20171231

:1, V
NORTH CAROLINA
Department of Environmental Qual

tr- q
IVA
A
'
--
NCDENR
North Carolina Department of Environment and Natural Resources
Pat McCrory
Governor
Nbh Finishers 41 LLC
NBH Finishers #41, LLC
118 Oak Hts Rd
Goldsboro, NC 27530
Dear Nbh Finishers 41 LLC:
John E. Skvarla, III
Secretary
October 1, 2014
Subject: Certificate of Coverage No. AWS820473
NBH Finishers #41, LLC
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
In accordance with your renewal request, we are hereby forwarding to you this Certificate of Coverage
(COC) issued to Nbh Finishers 41 LLC, authorizing the operation of the subject animal waste
management system in accordance with General Permit AWG 100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for NBH Finishers #41, LLC, located in Sampson County, with a swine animal capacity
of no greater than the following annual averages:
Wean to Finish: Feeder to Finish: 3864 Boar/Stud:
Wean to Feeder: Farrow to Wean: Gilts:
Farrow to Finish: Farrow to Feeder: Other:
If this is a Farrow to Wean or Farrow to Feeder operation, there may be one boar for each 15 sows. Where
boars are unnecessary, they may be replaced by an equivalent number of sows. Any of the sows may be
replaced by gilts at a rate of 4 gilts for every 3 sows.
This COC shall be effective from the date of issuance until September 30, 2019, and shall hereby void
Certificate of Coverage Number AWS820473 that was previously issued to this facility. Pursuant to this
COC, you are authorized and required to operate the system in conformity with the conditions and
limitations as specified in the General Permit, the facility's CAWMP, and this COC. An adequale system
for collecting and maintaining the required monitoring data and operational information must be
established for this facility. Any increase in waste production greater than the certified design capacity or
increase in number of animals authorized by this COC (as provided above) will require a modification to
the CAWMP and this COC and must be completed prior to actual increase in either wastewater flow or
number of animals.
Please read this COC and the enclosed State General Permit carefully. Please pay careful attention to the
record keeping and monitoring conditions in this permit. Record keeping forms are unchanged with this
General Permit. Please continue to use the same record keeping forms.
1636 Mail Service Center, Raleigh, North Carolina 27699.1636
Phorfe: 919-807-6464 1 Internet: htto:11www.ncdenr.Qov!
An Equal Opporturily 1 Affirmative ktion Employer - Mare in pars by recycled paper

w
If your Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
The issuance of this COC does not excuse the Permince from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
undcr this permit convey any property rights in either real or personal property.
Per NRCS standards a 100-foot separation shall be maintained between water supply wells and any
lagoon, storage pond, or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Program for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition II.22 of the General Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Tropical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You
may find detailed watch/warning information for your county by calling the Raleigh, NC National
Weather Service office at [phone], or by visiting their website at: http://www.wpather.gov/rah/
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office staff
may be reached at 910-433-3326. if you need additional information concerning this COC or the General
Permit, please contact the Animal Feeding Operations Program staff at [phone].
Sincerely,
for Thomas A. Reeder
Director, Division of Water Resources
Enclosure (General Permit AWG100000)
cc: (Certificate of Coverage only for all ccs)
Fayetteville Regional Office, Water Quality Regional Operations Section
Sampson County Health Department
Sampson County Soil and Water Conservation District
WQROS Central Files (Permit No. AWS820473)
AFO Notebooks
Murphy -Brown LLC

NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins Dee Freeman
Governor Director RECEIVED Secretary
April 27, 2011
NBH Finishers 41, LLC MAY 0 2 2011
NBH Finishers #41, LLC
118 Oak Heights Drive DENR-FAYETTEMLLE REGIONAL OFFICE
Goldsboro, NC 27530
Subject: Certificate of Coverage No. AWS820473
NBH Finishers #41, LLC
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
Dear NBH Finishers 41, LLC:
In accordance with your April 25, 2011 Notification of Change of Ownership and a request to change
operation type without exceeding the permitted steady state live weight request, we are hereby forwarding
to you this Certificate of Coverage (COC) issued to NBH Finishers 41, LLC, authorizing the operation of
the subject animal waste management system in accordance with General Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for the NBH Finishers #41, LLC, located in Sampson County, with a swine animal
capacity of no greater than the following annual averages:
Wean to Finish: Feeder to Finish: 3864 Boar/Stud:
Wean to Feeder: Farrow to Wean: Gilts:
Farrow to Finish: Farrow to Feeder: Other:
If this is a Farrow to Wean or Farrow to Feeder operation, there may be one boar for each 15 sows. Where
boars are unnecessary, they may be replaced by an equivalent number of sows. Any of the sows may be
replaced by gilts at,a rate of gilts for every 3 sows.
The COC shall be effective from the date of issuance until September 30, 2014, and shall hereby void
Certificate of Coverage Number AWS8.20473 dated October 1, 2009. Pursuant to this COC, you are
authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Please pay careful attention to the
record ke i
�ng and monitoring conditions in this Rganit. Record keepingkepping forms are unchanged with this
General Permit. Please continue to use the same record keeping forms.
16360 Mall Service Center, Raleigh, North Carolina 27699-1636
Location: 2728 Capital Blvd., Raleigh, North Carolina 27604 One
Phone: [phone] FAX: [phone] Customer Service: 1-877-623-6748 NOrthCarolina
Intemat: www.ncwaterquality.org r��
An Equal Opportunity 1 Alrmave Actiop, Employer Naturally

If your Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
The issuance of this COC does not excuse the Pernuttee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Per 15A NCAC 2T .0105(h) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the complianceboundary. Per NRCS standards a 100-foot separation
shall be maintained between water supply wells and any lagoon, storage pond. or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Pernut after the expiration date of the
General Permit, then an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Unit for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition 11.22 of the General Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Tropical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You
may find detailed watch/warning information for your county by calling the Raleigh, NC National
Weather Service office at [phone], or by visiting their website at: www.erh_noaa.gov/er/rah/
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Aquifer Protection Staff may be reached at [phone]_ If you need additional information
concerning this COC or the General Permit, please contact the Animal Feeding Operations Unit staff at
[phone].
Sincerely,
for Coleen H. Sullins
Enclosure (General Permit AWG 100000)
cc: (Certificate of Coverage only for aII ccs)
Fayetteville Regional Office, Aquifer Protection Section
Sampson County Health Department
Sampson County Soil and Water Conservation District
APS Central Files (Permit No. AWS820473)
AFO Notebooks

HCDFNR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves perdue Coleen H. Sullins Dee Freeman
Governor Director Secretary
May 15, 2009 ' `ECY1/EQ
Murphy -Brown, LLC
Farm 2141 MAY i S
P.O. Box 856
Warsaw, NC 28398 10W-FAYMUERMML0FRGE
Subject: Additional In orma ion
Application No. AWS820473
Farm 2141
Sampson County
Dear Murphy -Brown, LLC:
The Animal Feeding Operation Unit of Division of Water Quality's Aquifer Protection Section has completed a
preliminary review of your renewal permit application package. Additional information is required before we may
continue our review. Please address the following item(s) within 30 (thirty) days of receipt of this letter:
Chanee in animal numbers
The number of animals and operation type specified in your waste plan appear to be different than those
specified in your facility's permit application and most recent certificate of coverage (COC). Please
verify these numbers and, submit, if needed, a new Waste Utilization Plan or Nutrient Management Plan
to reflect the correct number of animals and operation type.
Please reference the subject application number when providing the requested information. All revised and/or
additional documentation shall be signed, sealed and dated, with two (2) copies submitted to my attention at the
address below. Please note that failure to provide this additional information on or before the above requested date
may result in your application being returned as incomplete.
Please be aware that you are responsible for meeting all requirements set forth in North Carolina rules and
regulations. Any oversights that occurred in the review of the subject application package are still the responsibility
of the applicant. In addition, any omissions made in responding to the above items shall result in future requests for
additional information.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a
civil penalty. Operation of your facility without coverage under a valid general permit would constitute a violation
of NCGS 143-215.1 and could result in assessments of civil penalties of up to $25,000 per day.
if you have any questions regarding this letter, please feel free to contact me at [phone]
cc: Fayetteville Regional Office, Aquifer Protection Section
Sampson County Soil and Water Conservation District
APS Files- AWS920473
Sincerely,
J. R. oshi
Animal Feeding Operations Unit
NAWN4
Aquifer Protection Section 1636 Mail Service Center
Internet: 3yww.newaterau or Location: 2728 Capital Boulevard
An Equal Opponto It/Afirmative Action Employer— 50% Recided110% Post Cormnter Paper
Raleigh, NC 27699-1636 Telephone: [phone]
Raleigh, NC27604 Fax 1: [phone]
Fax 2: [phone]
Customer Service: [phone]

Murphy -Brown, LLC
Grower(s):
Farm Name:
4/9/2009 2822 Hwy 24 West
3
P.O. Box 856
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Murphy -Brown, LLC
2141
County". Sampson
Farm Capacity:
Farrow to Wean 1205
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish
Storage Structure:
Storage Period:
Application Method:
Anaerobic Lagoon
>180 days
Irrigation
RECEIVED / DENRIOMQ
• uuifar or^t .
APR 16 2
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems,
RECEIVED
1 of R20
DW—FA*FE1UE lAI

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission_
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, W, tons, etc.):
Capacity Type Waste Produced per Animal Total
1205
Farrow to Wean
3212 gallyr
3,870,460 gallyr
Farrow to Feeder
4015 gal/yr
gal/yr
Farrow to Finish
10585 gallyr
gaVyr
Wean to Feeder
223 gal/yr
gallyr
Feeder to Finish
986 gat/yr
gal/yr
Total 3,870,460 gallyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (Ibs):
Capacity Type Nitrogen Produced per Animal Total
1205
Farrow to Wean
5.4 lbs/yr
6,507 lbs/yr
Farrow to Feeder
6.5 lbs/yr
Ibslyr
Farrow to Finish
26 lbs/yr
lbs/yr
Wean to Feeder
0.48 lbs/yr
lbs/yr
Feeder to Finish
2.3 lbs/yr
Ibslyr
Total 6,507 Ibslyr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 25
Total N Required 1st Year: 8112.5
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops: 8,112,50
Total Nitrogen Produced by Farm: 6,507.00
Nitrogen Balance for Crops: f 1,605.50)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2 of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized 1 unit yield
A
Barley
1.6 lbs N / bushel
B
Hybrid Bermudagrass - Grazed
50 lbs N 1 ton
C
Hybrid Bermudagrass - Hay
50 lbs N ! ton
D
Com - Grain
1.25 lbs N I bushel
E
Com - Silage
12 lbs N ! ton
F
Cotton
0- 12 lbs N I lbs lint
G
Fescue- Grazed
50 lbs N / ton
H
Fescue - Hay
50 lbs N / ton
I
Oats
1.3 lbs N 1 bushel
J
Rye
2.4 lbs N 1 bushel
K
Small Grain - Grazed
50 lbs N / acre
L
Small Grain - Hay
50 lbs N 1 acre
M
Grain Sorghum
2.5 lbs N / rwt
N
Wheat
2.4 lbs N / bushel
O
Soybean
4.0 lbs N / bushel
P
Pine Trees
40 ibs N / acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables_
See attached map showing the fields to be used for the utilization of animal waste.
4of8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PANT r/animal Farm Totall r
1205 Farrow to Wean 0.84 1012.2
Farrow to Feeder 1
Farrow to Finish 4.1
Wean to Feeder 0.072
Feeder to Finish 0.36
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 1012.2 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 5061 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 16 acreas of land. If you apply the sludge
to com at a rate of 125 pounds per acre, you will need 40.488 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to property
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
"This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil Application Rate Application Amount
Tract Hydrant Type Crop in/hr *inches
7476 IA & B Orangeburc B/C M 1
7476 1 C & D Wagram B/C 0.6 1
r-M-]

Additional Comments:
This plan revised to show a conversion from farrow to feeder to farrow to wean.
All other parameters remained the same as in the previous plan.
The nitrogen rate used for bermuda pasture in this plan represents a graze/hay
combination. Half of the bermuda will be removed by grazier and half by hay.
7 of 8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: 2141
Owner: Murphy -Brown, LLC
Manager: David Nordin
Owner/Manager Agreement;
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Murphy -Brown, LLC
Signature: _
/ Date -
Name of Manager (if different from owner): David Nordin
Signature:
Name of Technical Specialist:
Affiliation:
Address:
Signature:
M. Kevin Weston
Murphy -Brown, LLC.
2822 Hwy 24 West, PO Drawer 856
Warsaw, NC 28398
Telephone: [phone]
Date
Date
8of8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase, in the number of animals, method of
application, recievinq crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such thdrunoft
does not occur offsite or to surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order to control odor and flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than tat} feet of dwellings other than those owned
by the landowner_
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2of3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shalt be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3 of 3

/�13
��
Murphy -Brown, LLC 4/312009 2822 Hwy 24 West
P.O. BOX 856
Warsaw, NC 28398
Grower(s):
Farm Name:
NUTRIENT UTILIZATION PLAN
Murphy -Brown, LLC
2141
Farrow to Wean 1205
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish
Storage Structure:
Storage Period:
Application Method:
Anaerobic Lagoon
>180 days
Irrigation
.,, 1vcD1DENR1DIME
�(31!if Or tP.C�IQn A�Ik�{ft�UP R �01 I [�OF 10
IYR 0 g 20
M*I_ W Mau Ova
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems-
1 of 8

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based an typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft', tons, etc.):
Capacity Type Waste Produced per Animal Total
1205
Farrow to Wean
3212 gal/yr.
3,870,460 gal/yr
Farrow to Feeder
4015 gallyr
gallyr
Farrow to Finish
10585 gaUyr
gallyr
Wean to Feeder
223 gallyr
gal/yr
Feeder to Finish
986 gatlyr
gaVyr
Total 3,870,460 galtyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs):
Capacity T e Nitrogen Produced per Animal Total
1205
Farrow to Wean
5.4 lbs/yr
6,507 lbs/yr
Farrow to Feeder
6.5 lbs/yr
lbs/yr
Farrow to Finish
26 lbs/yr
lbs/yr
Wean to Feeder
0.48 lbs/yr
lbs/yr
Feeder to Finish
2.3 Ibslyr
Ibslyr
Total 6,507 lbs/yr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 25
Total N Required 1st Year: 8112.5
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops: 8,112.50
Total Nitrogen Produced by Farm: 6,507.00
Nitrogen Balance for Crops: (1,605.50)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2 of 8

2141
4/3/2009
'Receptior Area Specifications
Tract iziald Irrigalud Soil Ist Crop Time to lstCrop latCrup Lb3NIAc Lbs N Totai lbs N
NJ
mid=
3(a) of 0

Reception Area Specifications
3(b) of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results_
CROP CORE LEGEND
Crop Code Crop
A Barley
B Hybrid Bermudagrass - Grazed
C Hybrid Bermudagrass - Hay
D Corn - Grain
E Corn - Silage
F Cotton
G Fescue- Grazed
H Fescue - Hay
I Oats
J Rye
K Small Grain - Grazed
L Small Grain - Hay
M Grain Sorghum
N Wheat
O Soybean
P Pine Trees
Lbs N utilized / unit yield
1.6 Ibs N 1 bushel
50 Ibs N 1 ton
50 Ibs N f ton
1.25 Ibs N 1 bushel
12 ibs N / ton
0.12 Ibs N / Ibs lint
50 Ibs N 1 ton
50 Ibs N / ton
1.3 Ibs N 1 bushel
2.4 Ibs N / bushel
50 Ibs N / acre
50 Ibs N / acre
2.5 Ibs N / cwt
2.4 Ibs N / bushel
4.0 Ibs N / bushel
40 Ibs N / acre 1 yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm 5 eciFications PAN/animal Farm Totattyr
1205 Farrow to Wean 0.84 1012.2
Farrow to Feeder 1
Farrow to Finish 4.1
Wean to Feeder 0.072
Feeder to Finish 0.36
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 1012.2 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 5061 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 16 acreas of land. If you apply the sludge
to com at a rate of 125 pounds per acre, you will need 40.488 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removai.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
`This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions_
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 8

Application Rate Guide
The follovAng is provided as a guide for establishing application rates and amounts -
Soil Application Rate Application Amount
Tract Hydrant Type Crop in/hr inches
7476 1A & B Orangeburc B/C 0.5 1
7476 1 C & D Wagrarn B/C 0.6 1
6 of 8

Additional Comments:
This plan revised to show a conversion from farrow to feeder to farrow to wean_
All other parameters remained the same as in the previous plan.
The nitrogen rate used for bermuda pasture in this plan represents a grazelhay
combination. Half of the bermuda will be removed by grazing and half by hay.
7of8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: 2141
Owner: Murphy -Brown, LLC
Manager: David Nordin
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWO before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Murphy -Brown, LLC
Signature:
Name of Manager (if different from owner):
Signature:
Name of Technical Specialist:
Affiliation:
Address:
Telephone:
Signature:
David Nordin
M. Kevin Weston
Murphy -Brown, LLC.
2822 Hwy 24 West, PO Drawer 856
Warsaw, NC 28398
[phone]
Date
Date
Date
8 of 8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recievinq crop type, or available land.
Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips)-
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
B When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See 'Weather and Climate in North Carolina" for
guidance).
Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Wastelnutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells_
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion_
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels, pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of its a manner that meets North Carolina regulations.
3of3

Murphy -Brown, LLC
2141
PO Box 856
Warsaw NC 28398
Dear Murphy -Brown, LLC:
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P. E., Director
Division of Water Quality
October 1, 2004 RECEIVED
OCT 15 2004
DENR - FAYE1'TE111LLE REGIONAL OFHCE
Subject: Certificate of Coverage No. AWS820473
2141
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
On June 11, 2004, the North Carolina Division of Water Quality (Division) issued a revised State General
Permit for swine facilities. The General Permit was issued in accordance with the directive of Senate Bill
733 (Session Law 2003-28).
In accordance with your application received on February 13, 2003 and in accordance with the directive
of Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to
Murphy -Brown, LLC, authorizing the operation of the subject animal waste collection, treatment, storage
and land application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AWS820473 which expires October 1, 2004.
This approval shall consist of the.operation of this system including, but not limited to, the management
of animal waste from the 2141, located in Sampson County, with an animal capacity of no greater than an
annual average of 1205 Farrow to Wean swine and the application to land as specified in the facility's
Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or Farrow to Feeder
operation, there may also be one boar for each 15 sows. Where boars are unneccessary, they may be
replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a rate of 4 gilts
for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed S
General Permit, it contains new requirements in ai
previous State General Permit. Enclosed for your
revised forms used for record keeping and reporting
and monitoring conditions in this permit.
Aquifer Protection Section — Animal Feeding Operations Unit
1636 Mail Service Center, Raleigh, North Carolina 27699-1638
Late General Permit. Since this is a rexised State
Idition to most of the conditions contained in the
convenience is a package containing the new and
Please pgy careful attention to the record kegping
Phone: [phone] FAX: [phone] Internet: h2o.enr,state.nc.us
An Equal Opportunity/Affirmative Action Employer— 50% Recycled110% Post Consumer Paper
NorthCarOlina
,Xaturalillf

If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or .depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
----,of the facility.
Per 15A NCAC 2H .0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100 foot separation
shall be maintained between water supply wells and any Iagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 1 43-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Water Quality Staff may be reached at (9 i 0) 486-1541. if you need additional information concerning
this COC or the General Permit, please contact Duane Leith at (9I9) 715-6186.
Sincerely,
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc; (Certificate of Coverage only for all ce's)
Fayetteville Regional Office, Aquifer Protection Section
Sampson County Health Department
Sampson County Soil and Water Conservation District
Permit File AWS820473
APS Central Files

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: 2141
Owner: Carroll's Foods, Inc.
Manager:
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
llwe understand that I must own or have access to equipment, primarily irrigation equipment,
ft1 _on thi�Tsnv-ivci�eR4r�-r..,r'anagement plan. Th:..equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Carroll's Foods, Inc.
Signature: r �•
,// II Da e
Name of Manager (if different from owner): LZI /Y��+i n
Signature: ' 4 �j, ./� Y-6<Aa
ff Date
Name of Technical Specialist: Dawn Williamson
Affiliation: _ Murphy -Brown, LLC. T
Address: 2822 Hwy 24 West, PO Drawer 956
Warsaw, NC 28398
Telephone: [phone]
Signature:
6-(Q -(-)Z
Date
8of8
B00119210218

State of North Carolina
Department of Environment
and Natural Resources
Michael F. Easley, Governor
William G. Ross Jr., Secretary
Kerr T. Stevens, Director
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Carroll's Foods Inc
2141
PO Box 856
Warsaw NC 28398
Dear Carroll's Foods Inc:
/ • •
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCE5
April 6, 2001
`APR 16 2001
r!c_ia. Zvi r.C.
Subject: Notification for Wettable Acre Determination
Animal Waste Management System
2141
Facility Number 82-473
Sampson County
A letter dated January 15, 1999 was sent to advise you about concerns associated with Certified Animal
Waste Management Plans and the method by which the irrigated acres within the plans were calculated. Only
the acres that are wetted can be credited in the waste management plan as receiving waste application. Any
acreage within the plan that can not be reached by waste application equipment can not be used as part of your
plan.
An evaluation by Scott Faircloth on 2/16/99 was made to review the actual number of acres at your
facility that receive animal waste during land application. The evaluation of your facility has yielded one of
the following two results as indicated by the box marked with an "X".
Category 1:
❑ The evaluation of your facility could not be completed due to a lack of information. Please
contact your Technical Specialist to assist in providing Scott Faircloth the necessary
information to potentially exempt your facility from undergoing a complete wettable acre
determination. Please submit this information to Scott Faircloth, at 225 Green Street, Suite
714, Fayetteville, NC 28301, within in 90 days of the receipt of this letter. If you have any
questions please contact Scott Faircloth at [phone]. ff within 90 days you are
unable to provide Scott Faircloth with the information you are automatically required
to complete a Wettable Acre Determination as described by Category 2 below, within
180 days of receipt of this letter.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

Notification for Wettable Acre: Determination
Animal Waste Management System
Page 2
Category 2:
Your facility has been identified by the Department of Environment and Natural Resources
as a facility that may have overestimated the number of acres actually receiving animal
waste. Therefore, some or all of your fields may be exceeding the allowable loading rates
set in your Certified Animal Waste Management Plan.
In order to resolve this issue, please contact a designated Technical Specialist to have him
or her conduct a Wettable Acre Determination for your facility. The Technical Specialist must
be one that has been approved by the Soil and Water Conservation Commission to conduct
Wettable Acre Determinations. Many Technical Specialist with the N.C. Cooperative Extension
Service, the Soil and Water Conservation Districts, the Natural Resources Conservation
Service, and the Division of Soil and Water Conservation have received this special
designation. You may also contact a private Technical Specialist who has received this
designation, or a Professional Engineer.
All needed modifications to your Animal Waste Management System must be made and
the Wettable Acres Determination Certification must be returned to DWQ within the next
180 clays. If the needed modifications are not made and if the form is not returned within the
required time, DWQ will be forced to take appropriate enforcement actions to bring this facility
into compliance. These actions may include civil penalty assessments, permit revocation,
and/or injunctive relief_
Once a Wettable Acre Determination has been completed, a copy of the attached Wettable
Acre Determination Certification must be submitted to the address listed on the form. Please
note that both the owner and the Technical Specialist must sign the certification. A copy of all
the Wettable Acre Determination documentation that applies to your Waste Utilization Plan
must be kept at your facility. DWQ and the Division of Soil & Water Conservation Staff will
review all documentation during their annual visit of your facility. An additional copy must by
kept on file at the local Soil & Water Conservation District Office. Please note that if you install
or modify your irrigation system, a designated Irrigation Specialist or a Professional Engineer
must also sign the Wettable Acre Determination Certification.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Sonya Avant of our
Central Office staff at [phone] ext. 571.
Sincerely,
Kerr T. Stevens
cc: Fayetteville Regional Office
Sampson County Soil and Water Conservation District
Facility File
Carroll's foods, Inc.

id"4_ i KOL113 s
State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
Michael F. Easley, Governor
William G. Ross Jr., Secretary
Kerr T. Stevens, Director
April 4, 2001
lu 1:01HI ; 0101103A
To: Regional Water Quality Supervisor
f � s
NCDENR
NORTH CAROLINA DERARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
AWED
APR 9 2001
FA" LWEVILLE
From: Sonya Avant, Environmental Engineer AX0- REG. OFF10
Non -Discharge Compliance and Enforcement Unit
Subject: Wettable Acre Determinations for Certified and Permitted Operations
Attached is a list of the facilities in your respective regions that have been selected to receive
notification letters advising them that they have been flagged or pended for the month of March.
Each facility will be given written notice via certified mail. The notice will include a copy of the
certification form and a deadline for response.
I will also be sending copies of the final monthly list of selected facilities to the Division of Soil
and Water Conservation Operation Reviewers and Soil Water Conservation District Offices each
month along with an updated copy of all facilities in that county that have been either flagged or
pended. This will hopefully enable the Districts to be better able to schedule their workloads.
If you have any questions, please contact me at 733-5083 extension 571, or
[e-mail].
cc: Coleen Sullins
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% reeycled/10% post -consumer paper

Facilities Fiagged/Pended for April 6, 2001
Facility Flaggcd/Pending
Number Owner / Farm Name Address Status
WA PAN deticit WA Visit Date Integrator
FRO
09 — 66 Darrell Coble 2209 Old Fay Rd P2 952 5/17/1999 Murphy Family Farms
Garland NC 28441
Harvey Coble Nursery
09 —132 Darryl Hardee 3291 Rosindale Rd F1 989 919/1999 Murphy Family Fauns
Clarkton NC 28433
Terra Nova Limited
82 — 35 Rudcar Farms Inc PO Box 857 F4 393.72 4114/19" Prestage Farms
Clinton NC 28328
Rudcar Farms Inc
82 — 88 Ward Parker 9052 Lake Point Dr F4 491.49 4/23/1999 Prestage Farms
Clinton NC 28328
Ward Parker Farm
82 — ll2 Daanie Bradsher 2950 Moseley Ave F4 557 4/22/19" Murphy Family Farms
................................ Clinton NC 28328
Bradsher Farms 1, 2 & 3
82 —164 Billy Tyndall 6431 N US 421 Hwy F4 409 5/11/1999 Prestage Farms
Clinton NC 28328
B&B Tyndall Farm
82 —. 184 Sherwood R. Allcox 255 Fork Lake Drive F4 527.25 4/14/1999 Prestage Farms
Clinton NC: 28328
SX.A. Livestock
82 _ 186 Herbert G. Bowden 11294 Hohbton Highway F2 516 4/26/1999 Prestage Farms
Clinton NC 28328
Herbert G Bowden Farm

Facilities Flagged/Pended for April 6, 2001
Facility Fteggedmtraling
Number Owner / Farm Name address Status
WA PAN dencil WA Visit Date Integrator
82 - 189
Ray Horne
73 D&II Lane
P2
497
6/22/1999
Dogwood Farms
Turkey NC 28393
D&H Farm
82 — 199
Glenn D. Jones
81 Hardy Lane
F4
577.8
511 tl1999
Prestagc Farms
Clinton NC 28328
Glenn D. Jones Farm
82 318
Carroll's Foods Inc
PO Box 856
F2
4710
2119119"
Carroll's Foods Inc
.............................
Warsaw NC 28399
2703
82 --. 319
Carroll's Foods Inc
PO Box 856
F2
11428
2/1tV1999
Carroll's Foods Inc
Warsaw NC 28398
2702
82 -» 323
John Hendrix
145 Register -Sutton Road
F2
575
6/22/1999
_ _........... ....
Rose bill NC 28458
John Hendrix
82 — 335
Rexton Simmons
1128 HONEYCUTT
F4
494
5/5/1999
Murphy Family Farms
CLINTON, 28328
R&R Farms
82 .— 367
Zack McCullen,111.
1058 Wynn Road
F4
423
4/22/1999
Prestage Forms
....................................
Clinton NC 28328
D&% Farms
82 -.. 376
David Sinclair
6978 Faison Hwy.
F4
M2.5
3115/19"
Carroll's Foods, Inc.
Faison NC 28341
David Sinclair Farm

Facilities Flagged/Pended for April 6, 2001
Facility Flagged/Pending
Number Owner/ Farm Name Address Status WA PAN deficit WA Visit Date Integrator
82 —.426 Ben Parham 2391 Isaac Weeks Road F2 SSL9694 4/22/1999 Prestage Farms
Clinton NC 28328
Parham Farms
82 — 439 James Greg Harrell 9461 Tomahawk Highway F4 529 3/29/19" Murphy Family Farms
. Tomahawk TIC 28444
Greg Horrell Farm #2 & Addition
82 —444 Nash Johnson PO Box 25 F4 398 415/1999 Murphy Family Farms
....................... Clinton NC 28328
Boykin Lake Farm
82 — 448 Richard Whitfield 1670 Kenan Weeks Rd F4 504.99 4/29/1999 Murphy Family Farms
. Newton Grove 29366
Whitfield Livestock #1
82 —466 Carroll's Foods Inc PO Box 856 F2 9411 2/16/1999 Carroll's Foods Inc
Warsaw NC 28398
2537 and 2538
r■ ur+r�mr �i�r �n� ■ --m - ru w
82 — 472 Carroll's Foods Inc PO Box 856 F2 5275 2117/19" Carroll's Foods Inc
Warsaw NC 28398
2142
82 —473 Carroll's Foods Inc PO Box 856 F2 3597 2/16/19" Carroll's Foods Inc
Warsaw NC 28398
2141
82 —475 Carroll's Foods Inc PO Box 856 F4 16510 2/15/1999 Carroll's Foods Inc
Warsaw NC 2l1398
2106 and 2104
c'., C 5 �

Facilities Flagged/Pended for April 6, 2001
Facility Plugged/Pending
Number Owner Farm Name Address Status WA PAN deficit WA Visit Date Integrator
82 — 497 Carrell's Foods Inc PO Box 856 F4 3650 2/18/1999 Carroll's Foods Inc
.........I .................. Warsaw NC 28398
2122
lit — 598 Ruberl Naylor 2988 Church Road F4 393.15 4114/19" Murphy Family Farms
. Clinton NC 28328
Robert Naylor #3
82 — 01. Mark & Lora Godwin 1177 Eldridge Rd F2 404 NIO/1999 Murphy Family Farms
Newton Grove 28366
Godwin Nursery SC1141 & 2
82 — 619 Elbert Pearsall 997 Simmons !toad F4 520 4/26/1999 Prestage Farms
. Clinton NC 28328
Elbert Pearsall Farm
82 — 621 Jody Coombs P.O. Box 612 F4 463.4 4121/19" Prestage Farms
_...._..._....._...-•.•-•........ Clinton NC 29329
Joshua Coombs Farm

1%02/04/00 FRI 11:26 FAX [phone] Hunan Resources
a 016
Date:
Division of Water Quality
225 Gieen Street -Suite 714'
Fayetteville, NC 28314
Subject: Plan of Action
Name: r! 5 _Ln c.
Farm Name:
Facility No: �zp -g-7
Address: P. o anX Fr,S(, LJfx r s&.j N C.
Phone: -9ro • .343Y cicf 3 <f -
Checked below are the items to be carried out on the above farm:
✓ 1. Check inside and outside of buildings for water leakage and
water usage.
v'l 2. Repair and adjust any problems concerning excess water.
r/ 3. Inspect berms around the lagoons) to make sure that
water is no€ entering the system: Repairs will be made
where problems are identified.
4. Review flushing and pit recharge schedules. Reduce
flushing and pit recharges where possible.
5. Closely monitor the soaking. and clean -out of buildings
between herd placements. Reduce time and amount of
water usage as much as possible.
6. Check the moisture levels and crop conditions in all
spray fields. Utilize applications on winter cover crops
according to CWAMP (original or amended).
7. Utilize the 30 day prior to planting practice on those fields
to be planted in row crops.

V02/P4/00 FRI 11:26 FAX [phone] Human Resources
Q 017
V" S- Review CWAW and begin spraying on coastal Bermuda as
soon as plan allows (follow all regulations re_ runoff).
9. Obtain required permission from adjacent landowner to
spray on designated fields. Amend the CWANT before
any fields not currently on the CWAW are utilized.
,✓ 10. Investigate the feasibility of installing pressure reducers
on water lines.
11. Aerate soils to improve absorption and reduce potential for
runoff.
i
Additional practices to be used:
Signature_
Date 744. 2 c�no

.r
coPY ,
State of North Carolina �-�
Department of Environment, Health and Natural Resources
Division of Water Quality
tication
rvey
R A r1� ED �� (THIS FORM �i I�EPH4TOCOPIED FOR USE©SCAN ORIGINAL)
wA� 19�7
oG� 10eneral Permit - Liquid Animal Waste Operations
NT.rlll a fol ow ng questions have been completed utilizing information on file with the
Division. Please review the information for completeness and mare any corrections
which are appropriate. If a question has not been completed by the Division, please
complete as best as possible. Do not leave any question unanswered.
Application Date: , 10 - ') -q ,)
I. REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
Applicants Initials
I . One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
2. Two copies of a general location map indicating the location of the animal waste facilities and
held locations where animal waste is disposed:
3. Two copies of the Certified Animal Waste Management Plan (CAWMP). If the facility does
not have a CAWMP, one must be completed prior to submittal of a general permit application
for animal waste operations.
II. GENERAL INFORMATION:
1. Farm's name: _21441
2. Print Land Owner's name: _ CamQll's Foods Inc
3. Land Owners Mailing address: PO Box 8�6
City: Warsaw_ NC Zip: 28398
Telephone Number. 910-293-3434
4. County, where farm is located: Sampson
5. Farm Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a copy
of a county road map with the Iocation of the farm identified): On the east sides of SR 192Q approx..4 miles north of its
6. Print Farm Manager's name (if different from Land Owner): _ R V L F,,L-t V '1 C L.�=�
7. Lessee• / In tor' • ame (if applicable. please circle which type is listed): C d 1? L1^ i l , S �-- C (r, S.. Lq C
82 - 473
RECEIVED
NOV 18 1"1
FAYETTEVILLE
REQ. OFFICE
FORM: AWO-G-E 2/26/97
Page 1 of 3

4
e
III. OPERATION INFORMATION:
1. Farm No.: _U-473
2. Operation Description: Swine opgration
Farrow to Feeder
1000 - Certified Design Capacity
Is the above information correct? yes; n no. If no, correct below using the design capacity of the facility
Tvne Qf Swi .e No. of Animals Tye gf Poultry No. of Animals o e No. of Animal
0 Wean to Feeder 0 Layer 0 Dairy
0 Feeder to Finish 0 Non -Layer 0 Beef
0 Farrow to Wean (# sow) 0 Turkey
0 Farrow to Feeder (# sow)
0 Farrow to Finish (# sow)
Other Type of Livestock on the farm: No. of Animals:
3_ Acreage cleared and available for application: 32.00 '';Required Acreage (as listed in the CAWMP): 3 ,
4. Number of Lagoons: I ; Total Capacity: `t.g3 Cubic Feet (0) �� L QU�j Cl�la3
Number of Storage Ponds: : Total Capacity:
5. Is animal waste being applied on any Feld which has subsurface drains?
6. Are subsurface drains present in the vicinity of or under the lagoon?
I V . APPLICANT'S CERTIFICATION:
I,
Cubic Feet (ft3)
YES o (please circle one)
YES ar N (please circle one)
(Land Owner's name listed in question 1I.2), attest that
this application for _ _ t,— A lt4_011 _-� F tr14q It 1141 (Farm name listed in question II.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be retuntd,_to me as incomplete.
Signature
Date 1 D - `) A q
�J PDge-L = C A I11t" 11 b ved d s i .L 1%1 C
V . MANAGER'S CERTIFICATION: (complete only if different from the Land owner)
I, J� + t� Y �L LC—m A_ _ (Manager's name listed in question II.6), attest that this
application for C A Wo di 'e, P A k0aa. (Farm name listed in question H. l )
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be returned as incomplete. ,
Signature —I
Date 1� • ,�
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
PERMITS AND ENGINEERING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: (9I9) 733-5083
FORM: AWO-GE 2/26/97 Page 2 of 3

`Y1- ;'...� �.. �'?\•.' y. COPY-.
1v EQ %12L T I AXXG-I YE�7T PI"LN CyRTI?ICAT IOX FOR 8=ISTING FEEDLOTS
rIMM the complated form to the Division of Environmental Maaagauaaat at
4dam on the rsverse side cf this form.
Name of t'"ipppie se rint) : CAggx�'S
�4 Address
Phony No,:
County (of farm) :
=arm location: Latitude and Long itude:° q_'y$"/�$°lij' U" (required) . Also,
please attach a copy of a county road map with location identified.
Lype of operation (swine, layer, dairy, etc.): S
Design capacity (number of animals): c)ao ep_,
Average -size of operation (12 month population avg.): 00
Average acreaget needed for land application of waste (acres) -S6.5 t;i�Lcs1 dou[,i� cgpP�
asaasxaasasassaanagasasssassasstYas-sssasssssssirssasasaasasasasssssassassaaaaassaa
Technical Spscialiat Certification
As a technical specialist designated by the North Carolina Soil and Water
Conservation Commission pursuant to 1SA NCAC 6F .0005, I certify that the
existing animal waste management system For the farm named above has an animal
w�t5tG tilaiiny'cai�@i.t pia • tiat =get„ th= z=d =.-Intenance zt ndar�!s Mn'
specifications of the Division of Environmental Management, and the USDA -Soil
Conservation Service and/or the North Carolina Soil and Water Conservation.
Commission pursuant to 15A NCAC 2H.0217 and 15A NCAC 6F .0001-.0005. The
following elements and their corresponding minimum criteria have been verified
by me or other designated technical spec, alists and are included in the plan as
applicable: minimum separations (buffers); adequate quantity and amount of land
for waste utilization (or use of third party'); access or ownership of proper
:•taste application equipment; schedule for timing of applications; application
rates; loading rates; and the control of the discharge of pollutants from
stor:uwater runoff events less severe than the 25-year, 24-hour storm.
Hama of Technical SDecialiat (Please Print) = IAg L.4o63o*1
Affiliation (Agency). i
address : 90 02_AWgL 8 56 W'_d[. s9 39 a Phone No. '9yp �:V3, - 3 ¢3t
Signature: Date.
aet3asaassaaaa�yegasmyraaa7ssssssasassasssaaa�eat3�aaa5�s3saamaarysasagsses�s=zs
Oumer/Psaaager Agreement
'- (we) understand the operation and maintenance procedures established in the
approved animal waste management plan for the farm named above and will implement
these procedures. I (we) know that any expansion to the existing design capacity
of the waste treatment and storage system or construction of new facilities will
require a new certification to be submitted to the Division of Environmental
Management before the new animals are stocked. I (wa) also understand that there
must be no discharge of animal waste from this system to surface waters of the
state either directly through a man -mane conveyance or through runuzi from ¢
storm event less severe than the 25-year, 24-hour storm. The approved plan will
be filed at the farm and at the office of the local Soil and Water Conservation
District.
Name of owner (Please Print)
S ignat•-re : Date -
mama of Haaager, if different fwom owner (Please print): /
Signature:— d t4k, -�aR� - - _ Hate:_
hots: A change in land ownership requires notification or a new certification
(if the approved plan is changed) within 60 days of a title transfer.-
DEM USE ONLY: ACE)#

CARROLL'S FOODS, INC.
P. O. Drawer 856
WARSAW, NORTH CAROLINA 28398
FACILITY DESIGN AND
WASTE MANAGEMENT PLAN
Farm CARROLL'S FARM #2141
Name or Number
1000 SOW FARROW TO FEEDER
Farm Description
Location
SAMPSON COUNTY
Company Farm X
Contract Grower

l41
!31 7 t'r
.r{•t � � ma's 9 q¢� y! � � � � f31 ��
r
r
IT ,
/
(N I "
" b
s z
13
VIA
.�
r yy tltl i
Y��V � �'� YI•M � �� 1 ,III • �1 r ,, •1 � rr.1, • t 9 v:
u
�\0 � � ,I, q �Nw fir) r '',7 ,^ A y,� ♦ r- � � `� �I ;r'.
"J t
�� r

WASTE UTILIZATION PLAN
owners name--:CARROLL'S FOODS .2/4./ County:SAMPSON
Mail Address-: 0
Type of production unit ---- :FAR -FEED
Number of animal units-----: 1000
Type of waste facility ----- :Anaerobic Lagoon
Temporary storage period---: 180 days
Method of application ------ :IRRIGATION
Amount of animal waste produced-----------------: 7347 tons/year
Amount of plant available N produced by animals-: 6500 lbs./year
Commercial N to apply on planned acreage--------: 0 lbs./year
Your animal waste utilization plan has been specifically
developed for your swine operation. The plan is based on the
soil types, crops to be grown, and method of application for
your particular operation. The waste must be land applied at a
specified rate to prevent pollution of surface and/or ground
water. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops
where the waste is to be applied. This waste utilization plan
uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle and annual soil tests
are encouraged so that all plant nutrients can be balanced for
realistic yields of the crop to be grown.
Several factors are important in implementing your waste
utilization plan in order to maximize the fertilizer value of
the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the
needs of the crop to be grown and the nutrient content of the
waste. Do not apply more nitrogen than the crop can utilize.
Soil types are important as they have different infiltration
rates and leaching potential. Waste shall not be applied to
land eroding at greater than 5 tons per acre per year. Do not
apply waste on saturated soils or on land when the surface is
frozen. Either of these conditions may result in runoff to
surface waters. Wind conditions should also be considered to
avoid drift and downwind odor problems. To maximize the value
of nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or
not more than 30 days prior to planting. Soil incorporation
of waste will conserve nutrients and reduce odor problems.

Page 2
The acres needed to apply the animal waste is based on typical
nutrient content for this type of facility. Annual acreage
requirements may be more or less based on the waste analysis
report for your waste management facility.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract Field Soil Crop Yield Lbs. N Acres Lbs. N Month to
No. No. Type Code /Acre /Unit Used Apply
7476 4 WaB K
7476 4 WaB B
7476 2 OrA K
Available Nitrogen
N/A 100.00 25.0
4.7 50.00 25.0
N/A 100.00 6.5
Total 56.5
(includes commercial)
Surplus Or Deficit
Crop codes: Crop -unit
A=Barley-bu.
B=Bermudagrass(graze)-tons
C=Bermudagrass(hay)-tons
D=Corn (grain) -bu.
E=Corn(silage)-tons
F=Cotton-lbs. lint
G=Fescue(graze)-tons
H= Fescue(hay)-tons
2500 S-APRIL
5875 MAR-OCT
650 S-APRIL
9025
650G
-2525
I=Oats-bu.
J=Rye-bu.
K=Small grain(graze)-acre
L=Small grain(hay)-acre
M=Sorghum(grain)-cwt.
W=Wheat-bu.
Y=Fescue(pasture)-tons
Z=Bermudagrass (pasture) -tons

Page 3
If more commercial fertilizer is used than shown in this plan,
then additional acres of land may be needed. A three to fifteen
feet wide permanent grass filter strip should be seeded along all
ditches in fields that receive animal waste.
Additional comments:
--------------------
Prepared by: jaQ �• Title:R Date: 3 Z7 9S
concurred in by: Date:
Producer
I understand that I must own or have access to equipment,
primarily irrigation equipment, to land apply the animal waste
described in this waste utilization plan. This equipment must be
available at the appropriate pumping time such that no discharge
occurs from the lagoon in a 25-year 1-day storm event. I also
certify that the waste will be applied on the land according to
this plan at the appropriate times and at rates that no runoff
occurs.
Date:
Producer
Technical Specialist: �O Q Date: 2L-785
(Copy to producer and copy to case file)

I
rW

v 1 alI/9'e'L t1 0 A1vz *f6.s/ 0, rrrr[.-,fio.v-r
S� L,4AI/ Id -SG* �A E A ,< �-3 ��,.. did
X Z 3 0
r sS
s C /o r
7-Sk
T 5,�a�ms �il�u �s�, Z1 �.v,�� o x 70-/" CO
,4 .✓O � f v k ^/^ � v /--�,c 6��L.�.n � �Ti rn.aTdrs ,
Also �� % T�-.n or LAGao.✓ 171ryj,�,•-,s/�.✓.x i.►� �',oLG��A�ia.vr �� /�' sy� ,
- Cf/e,c �., rfi
h�a�>d�� a,.,
/,' / ��T- ,ai G �r 7r6 - ,ab .t-�T T -IiA-
i
a'
/��,C..•!/ 1°!1r' IhX-,OW7

= �a � i,�� s %i G,a i o ,��s .S/�� u ,r3f� � f� �,�•�� �'� T¢ G;e, a_ r47-,'o AJS
fliv /� . Sib yG, v> �� 2 �� JS T ,b�EL, o ..c/ /� J7 G���✓ /-%v i r'":i r.�l �
i y
a�'i,� T our /
14I
0 Ta,VS rL Ac -/, _33 /�J�Ce �, �n�✓"� /r pfG�'�G
SG ,&�4G e / A/ 14-1,0 /f"' /iirQ%�Q v 1��� 1214e (2,/ ce, Q-

0-
U. S.'DEPARTMENT OF AGRICULTURE NC-ENG-24
SOIL CONSERVATION SERVICE File Code ENG-11
8/72
Request for Engineering Assistance
NAME
�a RK UNIT �Qn tOToN
TYPE OF JOB
Drainage: 0. D. Tile Pump Group
Farm Pond: Stock Water Irrigation Fishing & Recreation -
Impounded Excavated
Irrigation Terracing Striperopping Grassed Waterways
Lagoon Other
WORK M BE CHARGED TO
CO-1 --P--�AP Watershed:
TYPE OF ASSISTANCE REMESTED
1. Needs and feasibility 5. Layout Assistance
2. Survey Assistance
5. Constr. Supervision
3. Design 7. Final Check
h. Design Approval
Estimated job class: I II III a) V
8. Other
RC&D .
DATE ASSI STANCE REQUESTED ��zr: •� — 3 0
�P�v/�v✓ n.../> /Q.f�r/�.v�/J Fo�� ��2. �- A r, av+/ o4d Sorrf� ri�/!1
,----='S",°
/p istrict Conservationist)
LATE: APPRov:
( Area Conservationist)

AINIMAL WASTE MANAGEMENT SYSTEM AGREeIENi
I. i&;/- Aders. 626-t-&-i AL, request assistance from the Soil.
Conservation Service through the Sampson Soil and Water
Conservation District for assistance in designing and supervising the
construction of an Animal waste Management System on my
farm.
I agree to construct this Animal Waste Management System in accordance with
the design provided me by the Soil Conservation Service. If for any reason
it becomes necessary to change this design, it must be approved by the Soil
Conservation Service prior to making the changes. .?ff the changes are not
approved by the Soil Conservation Service, no additional assistance will be
provided on this project.
The Sampson
Soil and Water Conservation District agrees to
provide technical assistance, subject to availability of personnel, in
designing the system and supervising construction until the project is
completed.
Following completion of construction, I agree to operate and maintain this
Animal Waste Management System in accordance with applicable local, State,
and federal water and air quality standards and the operation and
maintenance plan in my design.
I agree that any person representing the Sanpson Soil and Water
Conservation District may come upon the premises at any time to plan
design, supervise construction, or check the operation of this Animal Waste
Management Svstem.
Landowner Date
Sampson Soil and Water Conservation District
By: y—
District Representative Date

%
WASTE MkuAGEAENT BYSTEM
carrol�s a4I
T2SLE OE CONTENTS
1. cover Lett@r
Map
:. S Cs-Ewe-ss8 <Soi. lnvest.gation>
Lagoon Design Data
I tre2@n Coot@nt & acres Needed r_r EffIuent Dispos-!
3. Seeding Sp@cif.e=tons
2, L&Soon Site Computations
S. NC-ENG-42 :E=cay.tion>
9. % -ENG-12 <Embankment)
40. NA-ENG-1- (e=d)
li. NC-ENG-40 <eIan of Excavation waste Storage Lagoon
-L-. Typical view of A One -Stage Lagoon
18. Operation and Maintenance Plan
14. Topographical Map WZLagoon R Houses
15. Cross -Sections of Lagoon & Pad

UI •! I -i >_ D STATES
=.t` 3 -0 EAST ..' WAi ' S T REEELT D CE ARTMENT OF
---------------------------------------------------------------------
"i C'�.Sw ievi ex' '�htt a'.taCile+ �: >'ari dri II S�.+EC if iCaT,l +.:+r15 cah'ef Lil iy.
Rat,a i is ait fs:r v c[tir use at.ec C[t-sjs. it i S 5 t r o n 9 i Y
ec:ore; era ertii"Iat you, C[ur contraCto artd t-he SCri I Cortset"vatio.r.
Sery i c e }. erSonne ll ar= i n a: r`ernent as to how -Lhe waste i agoort
S tr. e c_+rts r'UL C:S personnel wi i i meet with ai 1
-iL L'rll [[rir y I E+`a a l ° � 'S - � 3 'ox ail �' i d'�S
r'r; i_•r �u �vi3. �iVc•r '��"st_ 3'L".E IWs +�dlrl
a.fiC irlclr', 3rtar t that ever -yore i.ltt[je'f stands '.that is
?iCr:L t 'i:eil S4 t ha ' i rsa i c+. nstt-uct i on fileets i[ I ar[5 �rld
SpI?c i 'i i C.' i Oit5 a' -Id use Jot-cafi i+e ccr i i f 1 r+l f=_:, pay°rftent ( if ACi
•=[s 4-`st:a"r = i S i fivr i :'t is. .
:e Ltd[, ir0,+rtsic[r:s :, 3ra es are tLIe t'cs� estirr:atie. The
L[Li i i iaeh` o:" LC+:t'4ractG.V- i S rL: �[CrIIs i L+ I k� {+: h' f I !-tai I ayf+ut art is
+i i i 15t i rl(I E �+ad5. SCD pe-so rt@fii �a I lrrl i to+s
t.ripaC i ty a LS friaiC,r' 4+:+I`tLl?`'rI i S the Frh- =.per des i ;ors andi
ortsi:h"UC. i irrl ;+f t,i'1E+ i dg[_[i_lii.
i1E aCtuai ara+:Iartt - rsiater-iai required fct" pads and dartl may
,V ar;i from the est i mates _ The design w i i I attempt to balance
utS arld f i 11S a C lose a p+_r5sit*fe i`� addI,i+_[Irat irEiic`.EI'Ia! 15
.-eqL i i,e a= er` cG tr't"s"'L[Ct i r:.n i s C:==,mp I etc on the lagoon, tE-e
c i_+rttr•actuh- and ownat` i I I r,eou - ; ate -[rl the pr i ce and I ocat i C[Es
of the L+ot-r-Cow area.
t Ei "sou I d tie note+ that C e r t i f i i a"t i C[rt +:+ t, 1 ag _ or, w i i I depend
u p -Irt ua ] spec i f i cat C'n-= be i na aletifop. ortartt items include
1en9tht width de'lth. 5ICpest"DSC+i1 Fiiacemerttt ccrrect
elevations ( top, t~,o tt -,rj;, d i schaar 3e p i pes ) , and seed i rs3.
NI CITE:
D e S I 'dal RegLi i reroe rIt :
Est—imate _,f E1,c avati i[r,:
Est i faate c+f Pai;:1:
Estimate of Dike: TOTAL
5 t i r a t e [_[ f 11, P, 7 C, i I R& 14 Li i r- e d
E.=i= s i 9r;ed By
_,ir{ cu.f't = e�96 cu.yds_
614i:'.9,8 cu.ft
U cu.ft -
61YL92, Cu.ft "^
4
1__
'7277 f cu.yds.
0 cu.yds.
' f74 cu.vds.
4)C) cu.yds.
1 i / .-.
Date
3
Des i gr, : ppi-ova 12,. i i, jC.I-,es

`I2 -'85
U. S. DEPARTMENT OF AGRICULTURE f
SOIL
SOIL MAP
CONSERVATION SERVICE
Owner C.aR?c�� s l�o Ds r.�
#.[
L
County �,�.e n�ys a.c
Operator
,fir.
Soil survey sheet (s) or code nos.
State
,c-.
Prepared by U. S- Department of Agriculture,
Aproxi mate scale /
with
Soil
Conservation
Service cooperating
Conservation District
s
Y37
•
B'.
a
i7 6
A
Iv`i
A-
So
370
g.�.3.
B
36s A;a
t�A';
s ,�;, . 376
t �r
w `(,A
r
.A� •3' 37- -.�. 370
=
;
B g•_
a.
370=
IDS
Y ~
371e'�_
76 A
3T6 _,37d
A
3ta5 37•;
°#
y
-
37
B
-5

m
MUNI

NAME:' Ca'rro|A Foods, Inc 441
ADDRESSt 01inton, NC
[NTRODUCTIOi
Carrot/s plans to construct a facility for a 1000 sow
farrow to feeder. This will he a company farm with total
confinement. Waste will be flushed underneath the slats
with recycled water' This system is not desioned for
sludge accumulation at owners request. Qu6se will be
pumpe� as
SITE CONDITIONS-.
----------------
The site is located East o? SR 1920 near Mo|toovii|e' It
is gently sloping on Wa8ram soils. The nearest house is
more than 2000 fee Plans are to establish
coastal bermuda hay|and in fields adjacent to the operation.
TYPE AND SIZE
OF OPERATION
CLASS
DESIGNED BY
DATE
APPROVED BY
DATE
PERMANENT STORAGE
1000 Hogs x
1000 Sow farrou�to feeder
IV
Howard Hobson
11/l9/90
Bi||y Jones
522 |bs per hog 1 Cu Ft per !b
TEMPORARY STORAGE
522000 |bs of animal x 1.35 cu' ft. of waste per day
per 1000 |bs of animal wt. x 180 days
RAINFALL LESS EVAPORATION
7" X 95584 sq' ft' surface area per 12^per Q
RAINFALL - 23 YR. 1 DAY STORM
7" X 95584 sq. it. of surface area per 12" per ft.
DESIGN STORAGE NEEDED ---------------------------------------
(PERMANENT STORAGE + TEMPORARY STORAGE + RAINFALL)
DESIGN STORAGE AVAILABLE ------------------------------------
522000 Cu Ft &"-
126846 Cu Ft 51~
�~
55757 Cu Ft
55757 Cu Ftv�_
704603 Cu Ft/u'x�;�
26096 Cu Ydy
724833 Cu Ft
26846 Cu Yds
TOTAL STORAGE ----------------------------------------------- 760561 Cu Ft
(PERMANENT STORAGE + TEMPORARY STORnGE + RAINFALL + 25 ','R) 28162 Cu Ft
MANURE AND URINE PRODUCTION
1()00
hoSs x
7.9 tons
per year
7900
T./yr.
NITRO6EN
IN NASTE
522000
lbs of animal
x .48 Qs
x 361 day/yr.
per 1000 >bs
of animal
wt.
91454
!bs/yr.
PHOSPHORUS
IN WASTE
522000
ins of animal
x .14 |bs
x 365 day/yr.
per 1000 lbs
of animal
wt'
P = Z6674
ibs/yr.
POTASSIUM
IN WASTE
522000
ibs of animal
x .2! |bs
x 365 Jay/yr.
per 1000 lbs
of animal
wt.
K = 40011
|bs/yr.

NAME':
I 't s
#41
i�i I N �j(. M
L;- ND 1-If\w.}i
ED
EMr.EDED FOR
L I QLi I D
I
B'—RAZED FESCUE �3 2 � i .,L:!�-�F.•�.
._ED T 11"-
YT 0kN 444 �4 4' r��.RG�:
-3RA
�. ONTROLLED GRAZING
COASTAL BERMUDAGRASS /4a SFr AC-REJ
HAYLAND jig - y AC EE
BEFORE ANY EFFLUENT .I S APPLIED TO T H:Y LANQ IT SHOULD LSE ANALYZED
TO DETERMINE THE E`,tACT NUM I ENT G'CIi:TEti4'1 . THE kINC DA LAB'ORAI !�tR
IN RALE I GH IS :MAKING SOME TEST ON A LIMITED LBAS I S. YOU SH!=+ULD
i- 1NTAC:T .
AGE Or-i IOMIC: SERVIL:ES DIVIF1'ION
NC:DA , SLUE RIDGE ROAD C:EINTER
BALE I GH N . C. :Z7r,1 i
PHA !i'vE .
WHEN AP 'LY NG Ti-IE EFFLUENT TO C:i^;Ct1= ....AND IT 2— D i. Sk: AND A
Yl_I fCl`4 C:RIJF` SEEDED IJh A F;L!W [: 'I !r r'>_ .N = c.. i 3 ! !-:-. E . ;=k. T k=r,3 !S— s =l1,'i .
SOME
4F THE COULD BE USED FOR' PLF'.�'�_Ir
DURING
THE GRI=IW I I�!t� SEASON.
PUMPING THE EFFLUENT 'WHEN i !!�E i T !=ice t;t!_-€ LF-T
THE FLUID LEVEL R'Af=HES _ 'T __ __
���.I �'1i_T L CIWE�, THE FLUID Ah!`f � ���M ��;✓ I—�'—outlet —�_ � r,c�-----
-1VIE� : THAN
------------------------
r"' LI r: YOUR
1 N F 01R-71A TIC,N
---------------------
- �.f^ w - � - h l _. —�_� k,�_ rir_Y". -' i ,Y:._ _ - Yi r. ♦: r. ': '-
LAND r ,-'L��-r1t Ii_I;.,i I_ik.:: GS"k-LI-.JE I';f .I.J �i; 1.,!s`, Ti"":�..
., ND T•;A 1;"41 ALL l I V .. =.ice} JI'kY.�
.L.1�11•" t_!I 1k'l `3� j 1 .»ii'„ . C_
. 1S`a 'ALL
- UC* PED I N' s_,'
.-� J
;
E:Atli F'LE 7
,ON
irs GALL-")s,41 ' ,`ACF,E T;tiC::
-� ''r: i:_ v'AL L'_ij, S'
- _i 7:w GALLFNvr--,
�50 AC CR'L

NAME�, Carro|�s #�1
3EEDING SPECIFICATlGNS
�REA rO BE SEE�ED
4PPLY THE ;-- ON- LOWTN�
USE THE SEED MIXTURE
INDICATED
( )
( �
( >
( )
(�� )
( >
3 AC.
300O LL"S' �-8-8 FE�TILIZER
4 i,m-iLOpl,IT�� LINE-STO�E
0 IALES SMALL GRAI� STRAW
0 LDS' FESCUE GRASS
0 L8S. OATS
0 LBS' DAHIA GRASS
0 LDS. WEEP IN8 LOVE GRABS
50 LID. S' HULLED DERMUDA GRASS
0 LES. UNnULLED �ERMUDA GRASS
150 LBS. RYE (GRAIN)
DIVERT ALL WATER TO A 5TABLE OUTLET
THE NEAREST RESIDENCE IS 2000 FT' �~--
B-EVPIT ION 50'00
�ESCRIPION
Nai| in base of 3'^ cak tree |ocated
S. of existinS farm �ath. Approxima te|y
130' W sta C

DEPTH L .'iREA OF TOP + AREA OF EOTT 1 OM + 4 X ARaA OF MIDSECTION]
VOLUME=--------- -------------------------- --------------------•--------_-
_ _ r
VOLUME--------------------------------------- -----.---------_----__
t ; r'
5��0
------------------
T
10.0 I. 434901
VOLUME =-------------------
_ 27
73�;?33
_4 -2- 4E;__ CU_ ; .
0LLIiE =---------
27
27/ OP,
95384 sq.£t.
704603 cu. ft. needed
.. NS I DE TOP MEASUREMENTS
SIDE SLOPES. 2.5.1
410 rT . x 230 FT.

JSurfaces:
-
Balanced
Existing
Tight Volumes Exp
nsion Q)
Expanded Volumes
Cut:
22774 . 87 C�'2 3r t 70,1
0.00
if
22774. 87
Fill:
22774-85
0.00
22774.35
Difference:
----------------`
0 02
Net Export:
-----------0.02
All volumes
are in cubic yards.
Grid cell size: 25.21 by 25.02
Original scale: 50.00ft/in
Project: CARROLL'S FOODS FARM 441
Drawing: SITE CALCULATIONS
Number: FARM 441
Location: SAMPSON COUNTY , N.C.
Sid Date: N/A
Engineer: K HORTON
Owner: CARROLL'S FOODS INC.
Estimator: J. HORTON
Prepared by: carrells foods using Sitework.

Confinement Building
Pit
TYPICAL VIEW OF A ONE -STAGE LAGOON SYSTEM
Top Width a —
Fluid Elevation 1-0.¢
S ss S S -22&:
" pipe (deeds to be adequately
supported)
Bottom Elevation 35.0
Sett led Top Elevation 1Z.0
SS 2:
/TREATMQ�IT
U I�aGaDt�
Depth = �lo, o

T h i :r i ;.ao0i, . S Fj_�a q-1emd F -,r Wa5..e t r 0 Ytrr'er: , '.r. ;I-: :Cs I ri; f LIM GFdI+r
C co :-i t r" !:+ i i i e L. : me: ; q is ; e +r f or ;. s : C }.+ !a f'; :'; t ,; f i u i F.i i e '. e , L o L,
reached frsay vary F, iAe . - t'le s4 i . cond i t i -iris and . i usii i n j oper-
a ri d aP,fL i i Cat i Ctn - i, Gda s to ,,.,tti,ter" i ; rec+-,ri i Z;'+1 a.`s -a r; a c c e C'v + 11=
m.e ti"si,i, d i gp+_+tea i Irr :3at i on i=+y us i r, s c, I . d sM ;, Mentor"
t:+ i vi+t Puri r u:+r- tr"ave I er i s he F,refei -red arI'j must e-= f i C i ierit
method to d i spu5e o-? the wf f i uerit 'l: rom .:pie I a3uur:, Liar e
si-ou I d be taken w1-sen at:,-+ I y i rI asta tC+ Prevent daflia3e t,,, the
crtoV,s ai'id tc: preve ri t rurii,ff T'r -,ffi "he f ! e I ds.
T1,e fie i I ow 1 ri9 i I; errs a.rE t+-+ be c a.rr i ed +:+Llt
i i. i-,ea i rt Piifsi0Llt ,_,f the I a3+-,on w+I-,ers f I u i d level reaches
i r:vent i,r thre :+ut let pi Fes :-js at a pre -determined
eIevatiC,i-r. qV.O
Stc+�, �,ufn*,-out bef r-.re the 1 agoor, deF,th i s I eSs thar, r_ feet
deep or at a pre-deterrair:ed depth. f tT�ri5 Prevents the
I i,s5 „n favoratt I e bac ter i a.)
_ I he r'EC -ifrltr 1"lijed amour, 6 u o :jll:' I V per I r"r i' at 1 3-+ri i S +-+tte
i nch r and mar; i mum .-ec+-1mmeride+� ��F�, s' i C at i +: r: rate i s 0.5
i-Ich per hour.
4. I't I S I''erci;riif, er:,J e+J tildt file trt:•'r1'(;merit I agc,i-Iri be p r e c h a r 3tz
to l/Z C,'I' it's ca— pac ity 1.,:, prever,"t e:':c essI tie odors duri rig
t,Eg I riC, I ;-:3 5 tcLjes i = }i ile sur+er at ] i_Frl , rr"=:iia:-g i rig reduces
the c+,r,+: en;.ra't i or., EFT' the i rs i t i a I was i.e enter i rIa flit= I ago -Cori,
L,se r ebb r e d u c i Is'3 CFFJC.r rs. So I i ds s b o u 1 d Lte cF_Fvereuw Lit
water" at al i z i mes .
�,. Keep vege;.ativrs ,err tisr efAbariic:rrief'rt ari+w the
i ayFFe}is as':d bu i I d I r, --:i ffioweFy.
%;. 'Rep . i r ari'y erode areas and estat+ i i sh I r, ve3etat i i,n
1 ��i",L C-I eaI:J.�Watf�r Act �tf 11''i 7 pyr�4I"s �'i�_+, i'G a �t Lse di s c h ahr ;� e/��,f
i i i! u t a r r't s I ri o 'al a e r s i, f h e W I'i I L e d 6 t a U ;R S 1 The e N, C
rr'1 ['Lf t-rl `J 1 r--Ir, ffIP rl 4 . Hta a th r a•"'!,� Itila Our aI1- Re c, u r c e
1 ;-IiVF.) r �+,sl:7 te�h'C1.44'r rrrlrl:y._i�,i'Ic,ri't �7ei. L � S.�II , 11t;, 4.VIe r NsF,isri-
w i i', i; I .;,..f r t,-, r ?rif,-+r' - i
A 1 � 5 Li f Fri t S= W a �, e ! t ,-, L+ 1. iw i '\i e i•_ .4 r"' +-, r�� ! •`- fl> ��. 1 �I �' i sl'� +;t ¢ I k W �.� C. 1
e+.Su3.:`.a am Fa v =eLL ? e 7ii1 i = L..
I't . Ar: ana l ys i s .- -7 t ie -.astir w a ter - t:;til be 4iFta i useu a,t
c fr,merc i a I I abur„t:jr i e's ,r- a a f -ee of ::i4.k_;S_i tier sarnFF I is 'a%:
{{r e p a r ',: m EaCli t+it;rIcLr. i1, FIanL Ai'ialj5is Lab
ri i I'fi i s l) i v 11!5 i+-+ r,
1 ur.' R i due Risa.d L:er! e
NC. �r=1

ATTACHMENT A
Page L
WASTE UTILIZATION PLAN
Producer / County,�,gMAo5 N_
Address Kind of operation /Cna
Type of Waste Facility L•esoaw'
Your animal waste management facility has been designed for a
given storage capaciy . When the waste reaches the designed
level, it must be land applied at a specified rate to prevent
pollution of surface and/or ground water. The plant nutrients
;Ln the .animal waste should be used to reduce the amount of
commercial fertilizer required for the crops on the fields
where the waste is to be applied. This waste utilization plan
uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle and, annual soil tests
are encouraged so that all plant nutrients can be balanced for
realistic yields of the crop to be grown.
Several factors are important in implementing your waste
utilization plan in order to maximize the fertilizer value of
the waste and to ensure that it is applied in an
environmentally safe manner: Always apply waste based on the
needs of the crop to be grown and the nutrient content of the
waste. Do not apply more nitrogen than the crop can utilize.
Soil types are important as they have different infiltration
rates and leaching potental. Waste shall not be applied to
land eroding at greater than S tons per acre per year. Do not
Apply waste on saturated soils or on land when the surface is
frozen. Either of these conditions may result in runoff to
surface waters. Wind conditions should also be considered to
avoid drift and downwind odor problems. To maximize the value
of nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or
not more than 30 days prior to planting. Injecting the waste
or disking will conserve nutrients and reduce odor problems.
The acres needed to apply the animal waste is based on typical
nutrient content for this type of facility. Acreage
requirements may be more or less based on the waste analysis
report from your waste management facility.
The design of your waste management facility is based on the
following:
Amount of Waste Produced Per Year:
42_animals x 7374.uaste /animal/yr ')Oo total waste
produced.

Standard
31E33.S'831E3:.15i1E:s6.#03�.36.75�K:>f.14]CIE.ii.30?4'37.5E31E3'.7.SS31E3?.'oC�a7.^p
W35.65436.6331f37.SQi1E37.43)K37.25*37.4331E37.603937.5531E37.50W37.33 E
31E37.4031E38.10*38.8031E38. 60*38.40)K38.05)*37.70*37, 75)K37.80)K37.75 �
31E37.55'#35.5331E39.5031E39.35.+Z?.28A38.58'la35.55 E36.5631E39.05A35.38
31E37.?6'i1E35.95'F46.1031E46. 16:l146.68'E3y.76:ik35'.46:iE38.85:�E35.3��39.66' .
37,321IF3R.45'*:5?.5&A46.7 Or* 40.Sr5'i€41.��0'�k46.96Y40.66:9E39.76 E35.50It39.�5
38.29 41.2B*,41.$@;iE42.4@*4re.10*41.BED�E4@.S5�EZ9.3�?iiE49.3@
40. ?W* 41. 51� 4 42.36'4 43.1 @'E 43. 43 iE 43. 75 i4 43.26 42. $@'4 41. 53 46.45* 41. 2R
43.20iE43.99'A44.46*45.0$'E45.05)K45,1@31E44.4]'E43.80' 42.70?Yc41.b7,iE42.1H'
44. @2'X 44. 903K 45. 72 * 45. 651E 4b. 4S* 4b .:Sib* 45. ob A 45. 05'* 43.33?fe 42. 60* 4a. 35'
144.8531e 45. 8931E 47.15'aE 48.TrO * 47.4$31E 47.5831E 45.'3$'E 4b. 303fc 44. 35:i: e � . SY3� 44.
-44.b5W-.4b.ZZ**47.5531E42.70%42.ZeA42.a5.31E47.35'146.653i445.55�fEa4.4rc4v.
44.45'Xc4b.90'X�47.553Yc4R . 19�4U.85',Vi4fb. F�0'E47.80',�c47.09?1E46. i5:K4:;.3��44.
' 44.72�"c4£.1534F4i.58'�E4R.G16�48.R2iE4£.. �5',iE47.ti5:4i45.S5?Yc46.1Sd�'=5.3��:+E4�,.
Plat o-F all data. far the _urfacp;
rxi=t ii g
11raw 1 rw:
Number:
b l l t UHLUULIa I l UNa
FARM #41
L.-,cat ion.
SAMPSON cOUNT1' N. C.
lid Date:
..
N,'A
Erlair,�ar '
3. HORTON
a�nPr'
OARML.L _S FOODS 19C.
_timatc+r.
... Kk9TUN
'7j6 c0
36.60
37.15
37.78
3S. 70
3U.76
4@.59
41.3@
41.9a
i3.5@
44.49
42.25
43, bb
Prepared bw, Carroll_ fCL-d2� u_in4 Sita-wOrk

4
0
Standard
55.�---------------------------------------------------------------------------- 2 68
. f 3is i 63 37.31
. f
1
1
I .
I .
I .
. 5.3
e .
t .
1 r
{ R� .................................r.......___...___...............
I
I
...............................................................................
4;--__--_-----'.................................... 35'. 65
4a. A
.2e 41
1.g� 41.5Z
43 . Wb 42 0
Sloping Area 1
45.
1. A6Y.
4 2
4 Gs
Plot of all dat-A, gor the? surfaco:
7"oPosed
Project: CARROLL'o FOODS FARM #41
Dr-aw i ^.7 : SITE CALCULAT Z ONS
Number: FARM #41
Locat ion: SAMPSON COUNTY . h;. C.
Bid Date:
lEngineer: s.HORTGN
Owner'. r iARMLL''' FQQD5$ :RC,•
Zitimator. J. .4MTM
Prepared bq,' carrell_ kncd_ using aiteworY.

1{
U. S. DEPARTMENT Of AGRICULTURE
Soil Conservation Service
LOCATION CODE -2-&7t:,
PLAN OF EXCAVATED WASTE STORAGE POND
NAME CA,GPorL,s S�Ilc. ACP U DATE AISTRIGT
L E„G r"
U DE SLOPEZ_�TO I J�
w
a .+ `j O AvE. TOP ELEV. �o�•
1
AVE. BOTT310 EL[W.
Mf. TN
NC-ENC-f
51F13
Volume . depth [area of top) + (area of bottom) + (4 x area midsection Ct
b
SUMMARY
Use of facility owL-
Capacity
Gallons
Volume Cost -sharing Cu. Ft.
Soil type B
B. M. description _ S"-
Elev. Sa,Ca, —
Bottom
Elev.
3o.0
Normal liquid level
Elev.
q.a.c
Storage for normal precip.(Ft)
+
Maximum liquid level
Elev.
Storage for;
25 yr. freq. precip.
(Ft.)
+ I, o
Crest ESW
Elev.
Stage (Ft.)
+_
Freeboard (Ft.)
+ 1.0
Top of Dam
Elev.
4-Z_0

c FOODS FARM U41
urv: SAMPSON COUNTY , N.C.
31D DATF: N/A
DRAWING: SITE CALCULATIONS
SURFACE: Propused
NON E
PAYDIRT SITEWORK
PROJECT SUMMARY REPORT
E1101 h Units
THICKNS CIRCUMIERENC£ AREA VOLUME CUT
TYPE Oft ELEV feat _ i �Irft .�.-._ _�.csr.ij_.1_ �cu..Y�.:..�....
Oloping Art±,% 1 SLn --- 1700.03 176743.00 0.00
* GROUP TOTAL.: NONE
** SURFACE TOTALSa: Proposed
DRAWING: SITE CALCULATIONS
BURFACE: Balanced
NONE
Sloping Ar eo 1 SLA - 1700.03 179743.00 0.00
* GROUP TOTAL: NONE 0.00
** SURFACE TOTALS: Balanced ** -� - 0.00
.I ...... 1................. I
SITE CALCULATIONS SUBTOTALS
2:47 ISM
05 NOV 90
PAGE 1
FILL..
22774.87 22774.85
Initial Surface: Existing SHRINK 0.00 % 0.00
Final Surface: Balanced SWGIL 0.00 1. 0.00
Perimeter; 2606.48 414943.34 22774.87 2277A.Q�
Grid cell _i:a: 25.00 (25.21 by 25.02)
Scale: 50.00 ft/in EXPORT 0.02
_____:=ea.cc=c==s==��s:•=�cz==w=xa:as;=�;ss.�x�w�s�z�u�-r�x�a.::aszazrs�s�cr.�c.-:���a^:--=x=�x:==�=cc===co=c�;c�ss��:���=�=r.7== ________--
*** PROJECT TOTALS ***
GROUP NONE TOTALS 3400.06 357487.80 0.00
LAYER TOTALS
STRUCTURE TOTALS
SLOPING AREA TOTALS
PERIMETER TOTALS
PROJECT SUBTOTALS
AVERAGE SHRINK 0.00%
AVERAGE SWELL. 0.00%
PROJECT TOTALS
0.00 0,00 0.00
0.00 0,00
3400.06 357487.00
2606.48 414R43.34
22774.87
0.00
.�.__` •97 4 97
22774.85
0.90
22774.85

qow Cron Gun Cart wars ;alvarnlzsd .pay ?3
sranaard eatliament_ an oatiarlal'_zw Profile
Gun Cart is 3iso avaiiacie.
Law Protlle Gun Cart (Gaivanized 3aay).
Performance Information
M c d e i A. 'W . nU T i SPRINKLS . ' wfiTM- '40 i 20 LCiES -N1 :
I (G_a.!A.) PRMURE PRMSuRE WMT)i L.`IG-,H t INC-4 :N
(P.S.Li 5 i1AYS
T-WA
2$0
104
70
240
1370
72
mutt
300
107
7a
ZSO ;
?3JS
77,
a C ]A
3�0
116
70
2W I
1380 I
gp
I SCMTKier
400 j
12S I
70
Z74
1= I
1GZ
j
450 I
138 I�I
70
280
1390 I
115
i
480 (
145 f
-M
290
13N
123
T37A
220
99
70
I 220
1160
j 56
wilts
250
104
70
230
1165
64
NE: S C N
3C0
113
70
245
1173
Fj
77
S'0R
R' I
Sprinkier ;
350
125
70
250
1175
90
400
137
70
253
1178
1C2
1
420
142
70
260
1180
107
T30A 1
130
104
I £0 j
210 {
loss
46
wim 1
200
111
I
60
215 S4
108a
51
NE" SCM Si1?CR
220 I
i29
70 j
225 S
1053
Sn
Sor;nKler
240 i
137
70
=0 i
1095
51
260
147 i
;a
235 }
loss !
57
Specifications
Model
T40A
T37A
T30A
M=Cer of lea
2
'
1
PE 7uG• I.D. An.;
4.0
17
3 0
PG'uaeLangtn;tt.;
1250
"050
1t.Cti
oty voignt (Ibs.1
31co
7_a0
4=0
Wi"gnt with water :•ICa.I
I Icaa
12390
14,
Seeed :Range ilne..:nins_i
10-a0
10 e0
7�:0
Tire Size
11"15
12,L.c15
7SLx:5
Shieping dim. (rL in.i
Long%" 13 15-4 13-3
•wlam 9•10 9-3 7-S
Mi"gnt 12-4 11-10 1134
•'late: 740A, , —, A .1G wneels - 3-3 wece
Paiyetfieiene 7woe Cn!y Wye :asigra, it :
`cr :^S _..r_t3^. _ :ii^_ a: _.3,'_ '; S __rS:23'eC f.r ,;se
�r�•=din ;la:_,.-»..s -_-_ ., s=��:��: =y a !-;fear
orc-r3T.e^. '.far"r.71.
PS7Lce ,ecarr -er=ar:S z-vasiaC:a
Ps %Ce _er.gtns . ��• ._=s �r _ - are ava:iame 3si
reC_;esi.
1
Standard Features
Paulai Inflow I urbine - I he neart -or Tie unve sys en.
T `i5 a=emely efficient mCiCr delivers quiet, smccm.
ccrnnucus ,,ver. ,ail d'te :eater ycu pump gees Zhreugh
:he 3crinkier. Vane Cf 'Lhe water is warred as in zellcws
Cr ~iscn drives.
Automatic Shutdown .or a-ureine ,rnotcr.
Heavy Duty Chassis and ..dme.
Speedometer.
Pressure Gauge.
Infinitely Adjustable Speed Ranges.
Speed Cairlpensator.
Miswrap Safety Stop.
PTO Rewind and Drive Shaft.
Gun Cart with adjustable wheel wictil.
Hose Guide 'a insure .roper packing of 'nose.
Turntable.
Nelson Slew Reverse Gun -:rith -ing nc4=-es.
Lifting Mecnanism .`cr -un --art.
Stacilizer Lacs =eav+i rJ ;:ark cr:ur. 5.ria_
4" Supply dose x :.:cr,c :fitf' nnaie -ing '.CCx
_.. c:er-
Pixed Saccl Brake eG ue5 no "icr` eclustmer:s.
r=10mof :utnT 7ur:n're ;r:a 7v --ragas zar. ::?
t
600 S. SC.iraaer Ave.. P.O. Box 290. Havana. IL s2544
Phone 3CS5413125 FAX _109154-:9a3
�eCx.:u:':T :r,': -_ -�- ��=.Y3'w --s -L_---rs: _-s et.'!t -lr '"w ]e��.'P!�l•. ��!"T �....�.J+ �e:L'�T..L1Gi .. n�sa:ll�et:s:�lN 4'�:�5 "3C7G v'aY1i71'-�.71 law 4Ic:.•rr+il'eG :Af•
.ti7R '_raw WC_S•I.-'!. _ar'ZTi7.NQ :.17 Y! Q.MC•'.=M
rQK 3•yp6W F7.� eem;r:rs,

North Carolina crricultural Extension Service
Agri -Waste -Management
&ola�ncal crlta Agr CUirurai =nQrrreerrng Vartlr Carolina Stare L"rrrvenrry
LIVESTOCK WAS TE SAMPL2iG, -kNA .YSIS _JUvD C A.L.CTa_-kTION
OF t �v� �PPLIC:�TION RATES
James C. Barker"
L Sk,%PLE COLLECTION
A Semi -Solid Lot lffam Ire
i. Saaped di m--Jv €rom lot imo spreadm
a) From'.oaded spreader% rollecr about ? lbs of mamm .5rom different locations using
aonmesallic =ilecmrs.
ii. From Storage
a) Collect about 2 lbs of -nanure from undCCr the surface crust zvoiding wing marerial and
using nonmetallic collecmrs
B. Liquid Manure Slurry
L Under-zlorted-door pit
a) Extend a '! " nonmetailic conduit opm on both ends into manure ro pit 2oor.
b) Sca1 upper end or conduit (e.tr, by placing a thumb over end of conduit) trapping
that has amered lower cad. remove and empty slurry into plastic bucket or nonmetallic
container.
c) Take subsamples from ; or more locations or at least 1 quart
d) mL-. and add about "'A pint to nonmetallic sample container.
iL Exterior storage basin or tank
a) NLzke sure manure aas be= well armed xah a liquid manure chopper -agitator
pump or aropeiler agiutor.
b) Take subsamples fom abort : pit Iocations. tom agi=or pump or from manure spreader
and place ina, plastic 1trcker.
• professor and Extension Spemalist. Biological and agricultural Enginecrmcr
Department. Noah Carolina Stale Univemry. Raleigia. NC

EL SAMPLE ?REPAR-k: AON .AND 7 -R..ANS'FER
A. Place sample into .in :.xrandable _ontainer that = be sealed. Rinse residues from container with
clean water but do no[ use dISMfes.Unxs_ strap& or treat in any other way.
3. ?a& sample in ice -e:iigarmr a or annsrer :o knit quickly_
C_ ;Maid-deiivery is most reiianie way of swim. ie �n�-.
D. Lf mailed_ protein sampie container with pang matertai such as ncwspaner, box or package with
wrapping Paper, and tape.
E_ Commercial sample containers and mailers are also available, Contact
L A& L Fasteim Agric uitural Lab. Inc.
7621 Whitepine Road
Richmond VA 23237
Ph- [phone]
I Fisher Scientific Co.
331j Winton Road
Raleigh. NC 27604
Ph: (919) 376-2-351
3. Poiyfoam Packers Corp-
'1320 5. Faster Avenue
Wtaeeling,ll. 60090
Ph: (312) 398,-4)110
4. N SCO
901 lanesvWc Avenue
Fort _Atkinson. WI 33533
Ph: (414) 363-_7446
F. Prwate mahlical labs are available. biz sample amalyses are cosdv.
G. The NCDA provides this service for North Carolina residents.
L Address: Norch Carolina Deparrmrw* or Agriculture
u. Agronomic Division
PlantJWasmSolution Advisory Section
Mue Ridge Road Enter
?. O. Sox 27647
Raleigh NC *7611
Pia: [phone]
Attn: Dr. Ray Campbell
aL Forward S4 along with the sample
iv, include the Following identiEcation information with sample:
a) Livestock spe``:es (dairy, swine_ turkey_ etc-)
b) Lvestoclk usage (swzne-nurse v. fintahing, :rev -breeders. brooderbouse. mower. number
flocks --ro,%m on Urrer: etc.)
�) ,VasiE tvTe (dair',-Fot `maned minum. �qwd slurry'. the -pit slusrv. Lagoon liquid sludge:
broiler-izots5e litter.-tockDiie)
v_ Routine irtaiv szs a :ora;ed on all samples: V, ?. ;t C:i �i7. eta S.: e �Lu 'n C r. 3
vi. Additional analyses periarmed upon ::west: DyL Mo. Cd NL ?b

a -.Ulm L .k-.i
w A.,` UTMlMkaON PLOT
Rz-:Z .-l— sit=—C.A,-LIOxs
I_ Anti waste shwa :Ot -=Cc Surtx= w== C z m2T- 3v =OX drift- 'nam-mrir ---orrverau=, Jir-- applicatim ar
dir=aL=are C.II mg a=;renn cr :and : �IIy dLSG.'lar�C at xdSC� �iIlCi i"�CGS s±lri3 'N3ICr S
? Tt=-- m1t aS a dO==M=n = :he dem%n mlaer :hat :he aroau=�Ib. = owns Jr 3ai 3 :fli3riT_'� 3 r :DI Ll3t �I
?amd an wnicz zo progeriy apply :he xaszc. If dLs -rodu= does hat own adecuare !=d to =pedy dispose of
waste hrishe shall pzztvida a rxpy of a motutzed agr=m=r with a laudawne: who is xithm a re smable prw mity.
aIlpwing h the rssc s he ?and :or xaste applir a Ir :s :hz :=ipounbdiry of :hc awn= of the Miry to secrarc
as update of the Waste ihil=ar�nn ?Ian xiLest luxe is a char; in the ope=on, -x==55c !z the avmber of animals
dOd of won, or SvaiaDle LmEti.
3. Ar&=i was= shall be applied m mew bur mnt --==d. :he ` iEmgm nerds `or :eaiisdc -vp yields aasd an soil type
ami-ibie moism : 5ista icnl dma, '_..mndzaon& and'_evei of -naaa7-Tmc units t= are re,sianons that
z�cz � :are of sppficiafln :ar or: e_ �Lr:.ra. ��ual nc?cs may �a :�sd :n are at -e3sisLc _•zaid �cics a :de
dismedon ai :bC Planner.
;. ?xima# = siLall -e aup .on Sad media; ?ems :ban ? :ors pea =e< .:ter. W2-S-� Wav '-c =UdCd ;a iaad :hat s
eroding 31 otore :han - L-ms = 1=ssi z = 10 :ons oar ac:-- per •,rc--r providia- pmss dlte: ;ems are insmile wae�
ranoff:eaves :hc 3ei�L (Seer 70 T C Smnrard - 93-rutty str:pst
5. Odes ma be rcduc:d by injecdu; the w'aSir or disidua 3t-- waste appIicailon. Waste shoved not '-Ic applied wb= Fhe
is danger ox drift:5m= the imz:mcn ddd.
6. Wben amoral waste, is to be applied an', suaj= to flooding it will be sail i=r--orate on canvenzionally dlld
cropk t Wh.= applied :a =nsc:-aacn zMer romps or T ssiancL ,he wash~ may oe orcad---m mxmdd the appii=on
does = oc= durmcr a seascn r= m coding (S= "'Mcart-ar and C'�imar in Vo."th
7, ldguid waste shall be applied ar :dress act: to r the soil inzilt=en .arc such dhat :-a: crT oes am o�zr w-fm or .o
srd - -arms and in a shod which does act muse drift 7�rcm :he sire during application- No pouding should occur
in order to control odor and lies.
S. Animal wasm shall hot be =Iiw to Saar. ails. daring. minzaU --venm or wh-z-n ;he sum^ = is a-cmm-n
9. Animal waste should be appi.ied on ac-t%,r-4v grz"vin; ---cps in such a -parr* that the -cp is aat mv_,-d wirh waste m
depth tb= would pror2mir growth. The aorcndni =or salt data ar t-om animal waste should also be conmderd.
10. Waste sac be appi. c -2�iiI -r -;vz^.r.- for spring pian:d =ps on sous -;�3th a 'Mga pate"ral
Waste aurrirnt Icading — an :hoc saris should be it'd :o a minimum and a suitable wizrcr --nvcr --up planted :D
tair sn W'ase_ m m=ts_ Was= shall act --c ap he-d mare :h n 30 days prior :o planting .f a =p or =aragcs ormidng
darma.aC; --
lL -kny hew swine 3c hi ,- sited on or C=6 - '_. 194. shall =amoiv With :he 0dowi i x. outc; of
Land arm into wi::_a writ_ S aD�.'� i." 3 .acrom ;�-z S a =m-! DnT= = a S'96Zne:sr— — S:LaiI v at .— =Cm
any -=ae== :xc e_:Y oaundx : azc ~m :.av s-tz=sn cr :vet other -= an mLcm . i= or -
-a—vacs.
vc
TMNF- 1996

;:rZ3r—1
WAS —I-- UTII. iMLON ?LAi.Y
Z:�LT�=7 �Cw?C->LTiONS
(c�rxrnud?
_animal -waste ether -.� swia: -va_� �m -�:.itizs si�3 on er a� C�aac :, I99', shall Zct ae applied �..:oser thou
S u== -va= I. 115 ''ie--t= =ay --c --=Ccd ;Cr waters that 3= not acz-..aarlal prcmdd aClegil;SLe `m6,,c=m
;i�ICr sZ L'S arc 7rLS = (Sep z - 9? }-
L2. Aaioaai wasW shall act Lc agplicd = o than 100 � cm wills
U. Animal worst= shall not Le appEd rinse han =00 of dwei?ings other ih= those owned ay i3ndowne».
14, Waste shall be appde— m a maau= =t :m �� cthc property Sad pudic m t-az-ways.
15. Arifrals waste shall act be dis.::.ar� �' atn surer mat.--s. �i:a nays or ,vesjands y a disc ., az v ovw-
spravu cr. A¢im.'al waste tnsy Le: anpizd tD priDr ravc:t� piand pravidd - Zac Lew: approve+ as and
a ¢pus st.'. Ly 3''-��=uir�.l rii .aril: ai waste =pliw m ,gssed -,vat-^ways shzil Lc 31 ag nosnic azz
had in a marm= that =mscs no : a=cff 7r dry -•orn :he sim.
I6_ Damcsac and Tnaus -i.0 -vast y xasaccwn ii*. shavers, _ail_:s. ni . w.� , ;hail act d.. :ao _t-
ammi waste roaaa -acnt Ysm=
1?. A promcd%+c -ver of anprvpriatc veg=mcr, awiil Lc :cliszed cn ail distzuicd stems (Igoon wncaak==ts, Lwms.
pspe :ams. mac.;. Arcs shall 5c _ as : ssary, to prole r. the v ,man. Vege=an such as trecs, shrubs, and
other wr7ady sp=C::S., == a.r-- i.imitM—' o a= Wnt-- apprcpria=. reas should be �t wvica and
art If-- Lagoon --==s and :L-_sr-s should x iu cc'= _--, riarly 'or mdea o wnsiorL lcaka-,M. ar disc3 .,=-
18. if Baal pr' &=,icn at the :5i i is :h= owns is :-aonsinfe Tor obtaining and imnicm=9ing a ':-Iosur_
pica' wmati will --Iiinraa c the possbWxy of an -iiapi disch , pollution 3Ld =.O=crs
19_ Waste iandlin s=uc'.ures. piping, fps. �=:s, .c.. slaouid Le at a:.d on a slat Izasis ;ICJCII Lrcrkdt7wms.
leaks, and spills. ?, Che&:isr should be `:--t on mtc.
20. Animal was c = be .assd in a romt m that includes •rczembles .and other waps :or direct. human consumption_
However, if mitnaI waste is used an cps ar direr '111=3 oansamption it should only be appiid preplan[ with :a
forth= applicuic s of 3aimal Wass dura, hr ---wp s=cm
21- Hi;hiy -risible Y==== mark='S shall Le mnallc.' to ==k the :co and Lo=m w=cv=cns a€ the t=porm-y stc rap
gm=ing volume) of 311 waste arm=r lagoons_ ?uraping shall �ie marsa;--d to main= the iquid icvci be_-*= :.s+
mars .k =arm. WIU Lc ^:.^.t]i. � :a =ark he -. x—,mum ;rcra;c volume :or wa= zorg= ponds.
a? Sail :em shad ::e mace vrcrf err . =� a= a i a warm �=vsss :,e :sic at :as: -wir_ =ch ear
wash zIIlimtion =1aa ?cui='� =hail �-c : tom prat :o acphcation. �oii �d •Nste 2z vsis r� iI ore _:
:wad ini=nis will zc _i=se+ :]f eT= � NC :""3L:cns.
Vas.

Swine Farm Waste Management Odor Control Checklist
Source
Cause
ilMPri to Miulullxe Odor Site Sjleclflc Practices —
Farlilslead
• LL
_ _
Swine"
_
,,,
111produclioli cgetalivc or Wooded buffia's;
ll" Remo n,raltfed best aitanagrinenl practices;
Gaud judgnicril laid cumluou sense
Annual body surfaces
*
Dilly manure -covered animals
Dry flours
Floor surfaces
0
Wu mamlte-covered floors
Slulled floors;
tu' Waterers located over sloltCd tluors;
11 1'eedets al Vigil end of solid lluurs;
a' Serape luatlurc buildup hula Hums;
(l Ihuleafloor venlilation for diyiog
Malauru colicctiull Mils
*
Ittirlc;
Ftuluent rttanure tcnluvill by ousel, pit tecit"go,
•
Piti ill microbial decomposition
or Scralic;
f) IJildertloor Venlilaliuli
Velililaliun exhaust fans
*
Volatile bases;
jV Fan maimeni nee;
Dust
19"'Ellicium air monnicul
luduur sus faces
*
Dust
Er Washduwn lrelween gluups of animals;
n Feed addilivcs;
0 Feeder covers;
0' Feed delivery dumispoul exlc cock -s to feeder
cuycrs
Flush Idnks
0Agitation
of recycled lagoon
n Flllsh lank covers;
liquid while (inks are lllling
n (extend till lines to near holuul oflanks will,
ailll-si hall VCINs
Flask alleys
*
Agilation during wastewater
L-1 IlutkafluorRush Willi mklcrll+atilt mililallun —v
vullyuplucc
Pia Iecllalge II0n1h
aAgllallwl
of recycled lagoon
lixlelld rechilige lines lu near butlulu of Ails ��--- —
liquid while pile are filling
with anti-5ipilun wills
Lift slaliuns
*
Agitalion during sunilt lank
l7 Sump lank covets � ----� — --
tilling and drawduwu
Outside chain cullccliun * Aglliditin during wastewater r) flux t:uvers
Or junction Ilexes Vullveyance
AMOC - Nuvcmt,cl 11. I996, Page 3

r
C
+J
Snurcl: _ _ Cause 11MPx fo bliulmlic flrllir .Sill: Specific Practices
End of draiupipcs al --- •---Agifaliou during wastewater n Extend discharge poiul of pipes undurncuth—___---- --�� --
lagoorl cu11►,cyance lagoau liquid level
Lagoon surfaces Volatile gas Culissions;. l&x Proper lagoon liquid capacity;
• Iliulugical mixing; A Correct lagoon startup procedurlss;
• Agitation [7ZMinimurn surface stets-to-vohune ratio;
Cl", Minimum agiialion When puillping;
13
Mechanical aeration;
❑
Proven biological additives
Irrigation sprllkkke�—
• I ligh pressure agitation;
17
Itrigate oil &Y flays With Will: of r10 wind; —
nozzles
. winll drift
ID" Minimum reconwiended ellcratillg 13r1:551IM;
to
/I1111np intake near laguou liquid sw face;'
n
Plllllll fiDlll scCollll-slagc lagotill
Slorage fan}: ur l,usill
i,iwial wicrobial dccuulpusitioa;
n
Maputo or midlevel loading;
surface
Mixing while filling;
❑
'!'sill: covers;
• Agilatiou WhCII I<ulptying
0
(lasill surfacc plats of solids;
Cl
12rovel1 biological uddilivcs of uxidaws
Stifling basin surfilcc -
- Paitial microbial decomposition;
❑
F'XICIld dranlid1h: i,lllldt 1IIhICIllCai11 lilluid
• tAixial; 1Y161C filling;
IUve1;
• Agitaltull w11CII cnlluyinl;
C7
lteilluvc settled solids rla;llimly
Manure, slurry ur shidge
• Agitalioa witen spreading;
Cl
Soil iujecliolt of slurry/sludges;--
spreader outsets
6 Walk gas emissions
Cl
Wash residual utanure fruin sprca4cr after use;
C1 Proven biological additives ur Oxidailts
Uncovered ulurlinc,— - Vol:ltils; gas emissions while Sail iiljeclioli of sllurylsludl;cs
slutly Ur Sll d6tl Ull IMA shying ❑ Soil incorporalion wiihiu aft hrs.;
Surfaccs
❑ Spread in lion uniform layers fur rapid dtying;
C7 t'roven biolugil ul additives ur uxillul:u
❑cad annuals Careass decuniposililnl Props r disposiliull of curca5s4s
D,:;ILi aliilual did,u:,ai - - r'al cuss decoinpus111r111
pits
hlciiicraiur; • ll,i:um ,le1e Cuulbu5liun
l7 I'ruper lacutiunlculisllucfiuu ufdispusa! Ails
11-SecunllaryslgcAbuluci--.--.-..__W_._._.,.._.—_--__.___—•-
AN( I luvelobo- 11. 1996, Page •1 , �'

Cruse BbIT's to hfinindic Odur Sile pp clfie Practices
Standing watct arululkl 0 1„II}ruper drainage; 19 Grade and larldscupe such dial water drains
facilities 0 Microbial decomposition of away from facilities
u,1;:utiic rltartcr
Manure tracked wuu I'uu+ly uluu,lau+ed access roads i arrrr access road u,ul++tcnaute
pudic roads (Lunt Wlnl
ACCC55
Additional IllfOrin41i0lt : _ Availatrlc From
Swine Manure Managcarcttl ; 0200 Rule/11NIP Packet NCSU, C:o+utly Extension Cenler
Swine I'rueluctiurt Falnl I'uleulial (Mur Sources and Remedies ; EBAB Fact Shcel NCSIJ - 11AI:
Swine Pruductiuu Facility hhuu,rc Munagemeul; Pit Itecliarga - lagoon Treatiacut; CRAR 128-88 NCSU - HAI:
Swine I'+u,luctiull Facibly Nhoure Management: Underlloor Flush-1-trgoun Trealmeot ; GIJAli 129.88 NCSIJ - IIA F
Lagouu Desll;li ur,k1 ldalla, c+llent for I.Ivesluck Manure Treatment and SIUr'age ; F110 103-83 NCSU - IIAIi
Caliblati.11l of H-mulc all'i Wo'-14; eater Application liquipmcot ; EISAU Fact Shcct NCSIJ - 11AI:
Cumiullimg 1),Ions fi iboj S%viuc IludAings ; I'lll-33 NCStJ - Swine Cxicnsiun
Lnviruu,ucmal A:,,wij+Yt:C i'+ul;la,rl ; IJI'PC Manual NC fork Producers Assoc
Options lur t,lanaging Odur ; a rcpulz from thts Swine Wor 1'ask Fome NCSU Agd Ci mummicatiuns
Nuisance Ctmt:cl,is io luiwal Alciuu+c t►lxnat;cn+enl: OdLifs and Mies ; PROM, 1995 C.nl+fere,lCe I'+ncce,llugs Florida Cuoperalivc t_xlcnsiun
Ai\1 • l tuvcIIi L:f l I, I'l'JI�, l :,wc 5

Insect Control Checklist for Animal Operations
Source Cause UNIPS to Control Insects Site Specific PI-Melleys
_ldc�uldSysieuia�_-
Flush Gullets • Accumulaliuil of solids n FWAt systwin is dwsigiwd and olwwied
sufliciwally to rwnuvc aceiuuuliacti sulids fruut
gullws us designed.
n iicmuve bridging of accunruli aed solids at
diSchw u
Laguuils and l'ils Cruslca Solids f7 hiaiulaill (agoutis, s:uling basills and piss where
Ilesi brcwaing is apputall to lniui,niLc Ili:
ciusting ufsulids to a delitll of no utoiw luau 6 -
g iuclics uver idol: iliac 301'0 of sue thee.
f %L'CSSIVL Vegc li1IIVw • �I�ccaylil�' Vegetation lAWililalli VwgwlaliV: Cuiliiul along banks of
Oluwlli lapuini and ulliwr itapoundownis to inwvvii
accu n dalluli Ul ducayisig Vtig4lalivo inallcr
aluug wuiet's edge un iucituul►duicnl's pwriukdCI-.
T Illy Sysleuis
Feeders • I -cud Spillage n llesigu, upcialw alid niainlinn ked sybivins—
Ifuukcrs dill troughs) lu uiinimiw lily
accuutulaNuti of aecaying wiwage.
n Clwan up spillage: on a roulinc basis [t;.g., 7 - 10
cloy inlcrval during Smm11e1.6 l5-10 clay illlCFVdl
duriug winler),
Feed Slisiaga • Accuitiuhaiuns of feed residues n Neaucw uurisltire accunwiatiuu within aria --
asuulid inisile lialw Pet sululcl ul' lcwa slurage
arwas by insuring diainslge, away lium bile
aud/ur piuviding aawyu-alc cuatuinwent
cuveied ilia lur bcewei's giuiu and similar high
uwislure grain pruducls).
n Inspect fur and seluuwc or Irlcak till acclinlulawd
wlids in filler bllips around l;cd slurage as
tiwwded.
AM ` - Nuvcml,cr 11, 1996, l'aga

Facility Number and Name: Carroll's 82-473 Farm 2141
Instructions on last page
P��
ARM i4
tim �_
E—_ Disehar a .s�
High Freeboards
Wettable Acres
�
Description of Concern`
�` ' ,, ,.-����.�,.,k - � - �x �
Al-�,
NOD issued 3-17-00 in response to company
reported lagoon level of 13 on 1-31-00.
This facility as flagged for a WA
determination.
,
2 MA
SSSa _ _
xM��S;;L
acer-..;•. 'T� to �:. �y s_w ...xr �: i .
Response`
����'
_ Y _
x
_ -
The extreme rainfall event associated with
hurricanes Floyd/Dem-tis elevated ]agoon levels in
The determination is complete and the
certification was mailed to DWQ - Raleigh on
the fall of 1999. The high levels persisted through
4-16-01.
-��
March 2000 because opportunities for land
application were limited by further rainfall,
�" zx _ �
- �,-
x
saturated fields, and PAN limitations on winter
crops.
.M

Facility Number and Name: Carroll's 82-473 Farm 2141
Instructions on last gag
ga-
FM E&
-7 �kP z
-0-
;.M. I -2�
L
•B-P A� U
-M
r it
--4 1 n' 7
�P7PPJ P -.sqgs
I sues s
Description of Concern
�c�
13 25-01, 1, M "01,500"
REM IN
�
s�g-RASOMM
M
-
01-
AMM
Az--
g�
W SM I NO
AN•
MMORM
N
Ell .fit_.-
gg
VMw"M qG
IGE, e",Q•--W
54,
Mu,
is M
K S W�-
- w A N--
2�
Mum -ft�
gg,-,
®R
-Mz-U-M :
M M
Z;2a Q,--,;
1
AWE
g EM
-M
�M-Mo -
TF
.1
�W Mt
- - - ME
F-.
Response
1-71 R
-M-
N 'Y?
A
g IS :!We MPL i "R
­07ME M 90 M
E ENE
Wt �-�
'3 2
lA
M �Q itt 2
IM
MEN
tea.W.
M
:"a- o k
IN.....
90, M
R%'-sLIRM
-14L gf 'Ek4,P
E, Rvg,
FIR
0 -----FL M-
Mz
.......... mg-:;A� �,5,5-4 �51-
-4
RR-M,
�=,- I -
PC.
W K
iz
MM, -
L
m kit
_wmgg
1 a
g-g-
—XI, 5; -
i I'S MAW
�M
Mr-23W
I;P
=cxS 'x
SIMI--: MUM
E-
`Fim-
ARM,•
! 90
MO.
vA
'�-,'-..=..-s:_-�,."5a="f P:,y, " ._:.u._ '•xiPz+^
x R-� EEL
iW LB,
W
MOM-
g—g-w-
Vf
g
r.
Mi.5
4P
........ ...... -k�
-g
- -4�� A
-,, t nh�
, WOMM --M
, zt�!F.
M, Wr�� M
R
1w
`3
M
M RA;
M PHR �
T,4
W - - n5, P Ram—
PM; M g - A - BUM
5
1- Pw r,�- rEE
M-9 M--
Ric't
nx--
-� go,& P&M
W h-E
M
Iq
T-NA
MI-M
Y: M z
19P=
•M
T6nMN
�W
...............

i
1 Concerns are based upon DWQ records consisting of deficiencies noted in state inspection reports, NOVs, penalty assessments and/or reports submitted to DWQ by the farm. Carefully
review your records to identify the specific concern or concerns and then describe the concern under the appropriate heading together with a reference to the specific record and the date of
the record (Le_, inspection report dated or NOV dated ___). With the exception of "discharges," which cover calendar year 2000, concerns are based on DWQ records for the
calendar years beginning January 1, 1996, and ending December 31, 2000.
z Describe in as much detail as possible how the concern has been addressed, or, if it has not been addressed, the measures the farm intends to undertake to address the concern and a
schedule for completing the measures.
3 if subsurface drains are present, state whether you know that the drain(s) is discharging groundwater uncontaminated by hog waste, and if so, the basis for that conclusion.

Facility Number and Name: Carroll's 82-473, Farm 2141
Description of Concern
Response
Freeboards
NOD issued 3-17-00 in response to company
reported lagoon level of 13"on 1-31-00.
The extreme rainfall event associated with
Instructions on last page
Wettable Acres
This facility was flagged for a WA
determination.
The determination is complete and the
hurricanes Floyd/Dennis elevated lagoon levels in certification was mailed to DWQ — Raleigh on
the fall of 1999. The high levels persisted through 4-16-01.
March 2000 because opportunities for land
application were limited by further rainfall,
saturated fields, and PAN limitations on winter
crops.

r'4
Lei
E
E
z
4 W
A Pto
s Ali
top
r
144441 i4k, 1'��
Li
SSW
. 57
0.
INV
W00-
Moo mm
jC
r?
v. -.rwrl
L
V.4
P.
AT
how,
"Ilk
nit
if
'j, r-j Amy V't;gjlft"5 4rjyl 4'. 1,�
Q toy" 2
j
1) 07�­.
4. ir .0
1 cc W.
1 A�d, QQ
A
mow
ft AIR,$, MY
I . . . . . .
qW,
11 �Vj
�Al :luzir
V4
WITT
41 4!,!,
ow
40
�R y
11 4V11 ....
41
, e'01,
to
4%
j. lip,
ev
............. .............
Rol',
OW1
54, a W , .1
in j
_4
h4i
00 ONE
14. oil
WE F F2
I .: I
U
MOW =MW in IV,
j� i4
owl.
0�
pe
Pit
Tfi d,
1�1- 41
�j K­ A 1— 441*
1" "1
a f 4,�,
Iva,
A's
WA
LY
4.0
r
NW) V 100.
% 'A'
moo
R to- Q
V.q
VEI I
k 644P_ '-pt
tin,
ny,
Aq. 4 Sm
sm W,
int�l,;At I
'j,
�',
M-40
m,
h
Y 41,
lug p t
A0.04A, 1
4
.4
" I `
�14 A
I KIT-,
son
j �.j J,
WN-A
gj� tW., I" i,
Plif. .1, A- ff� .1
j
NINVA
tg
k k ft
T
CL
SIM
j
r")

Concerns are based upon DWQ records consisting of deficiencies noted in state inspection reports, NOVs, penalty assessments and/or reports submitted to DWQ by the farm. Carefully.
review your records to identify the specific concern or concerns and then describe the concern under the appropriate heading together with a reference to the specific record and the date of
the record (i.e., inspection report dated or NOV dated ..._). With the exception of "discharges," which cover calendar year 2000, concerns are based on DWQ records for the
calendar years beginning January 1, 1996, and ending December 31, 2000.
2 Describe in as much detail as possible how the concern has been addressed, or, if it has not been addressed, the measures the farm intends to undertake to address the concern and a
schedule for completing the measures.
3 if subsurface drains are present, state whether you know that the drain(s) is discharging groundwater uncontaminated by hog waste, and if so, the basis for that conclusion.
3