760010_PERMITTING_20171231

acut. of EMR
NCDENR NOV 0 6 2015
North Carolina Department of Environment and Natural Resources : f�Iot Salem
R� ionalOffiw
Pat McCrory John E. Skvarla, ill
Governor Secretary
October 1. 2014
Christopher Allan Redding
'Redding Fartn
4126 Baker Farm Rd
Sophia, NC 27350 ✓
Subject: Certificatc of Coverage No. AWS760010
Redding Farm
Swine Waste Collection, "Treatment,
Storage and Application System
Randolph County
Dear Christoplicr Allan Redding:
In accordance with your renewal request, we are hereby forwarding to you this Certificate of Covcragc
(COC) issued to Christopher Allan Redding, authorizing the operation of the subject animal waste
management system in accordance with General Pcrniit AWG I00000.
This approval shall consist of the operation of tliis system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWNIV) for Redding Faris, located in Randolph County, with a swine animal capacity of no
greater than the following annual averages:
Wean to Finish: Feeder to Finish: 1900 Boar/Stud:
Wean to Feeder: Farrow to Wean: Gilts:
Farrow to Finish: Farrow to Feedcr: Other:
If this is a Farrow to Wean or Farrow to Feeder operation, there may be one boar for each 15 sows. Where
boars are unnecessary, they may be replaced by all equivalent number of sows. Any of the sows may be
replaced by gilts at a rate of4 gilts for every 3 sows.
This COC shall be effective front the date of issuance until September 30, 2019. and shall hereby void
Certificate of' Coverage Number AWS760010 that was previously issued to this facility. Pursuant to this
COC, you are authorized and required to operate the system in confor ility with the conditions and
limitations as specified in the General Pennit, the facility's CAWMP, and this COC. Ali adequate system
for collecting and maintaining the required monitoring data and operational information must be
established for this facility. Any increase in waste production greater than the certified design capacity or
increase in number of animals authorized by this COC (as provided above) will require a modification to
the CAWMI' and this COC and must be completed prior to actual increase in either wastewater flow or
number of animals.
Please read this COC and the enclosed State General Permit carefully_ Please pay careful attention to the
= record kee in and monitoring conditions in this crtnit. Record keeping fames are Unchanged with this
General Permit. Please continue to use the same record keeping forms.
1636 Nail Service Center, Raleigh, North Carolina 27699-1636
Phone: [phone] Inlernet: http_ A ww.ncdenr.govf
An Equal opportunity\Affirm@tive AcMn Employer— Made in part by recycled paper

If your Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation of' future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to Have a new WUP developed.
The issuance of this COC does not excuse the Pennittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local. state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Per NRCS standards a 100-foot separation shall be maintained between water supply wells and any
lagoon, storage pond, or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAI MP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If any parts, requirements, or limitations contained In this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Program for infornation on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition 1I.22 of the General Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Tropical Storm Warning.,
or a Flood Watch associated with a tropical system for the county in which the ftcility is located. You
may find detailed watch/warning information for your county by calling the Raleigh, NC National
Weather Service office at [phone], or by visiting their website at: littp://w%vw.we-,itlier.gov/rah/
This facility is located in a county covered by our Winston-Salem Regional Office. The Regional Office
staff may be reached at 919-807-6464, If you need additional infonnation concerning this CDC or the
General Permit, please contact the Animal Fueding Operations Program staff at (9I9) 807-6464.
Sincerely.
for Thomas A. Reeder
Director, Division of Water Resources
Enclosure (General Permit AWG 100000)
cc: (Certif ieate of Coverage only for all ccs)
Winston-Salem Regional Office, Water Quality Regional Operations Section
Randolph County Ilcalth Department
Randolph County Sol] and Water Conservation District
WQROS Central Files (Permit No. AWS760010)
AFO Notebooks
N G Purvis Farnis Inc

WArF9 Michael F. Easley, Governor
QG William G. Ross Jr., Secretary
F North Carolina Department of Environment and Natural Resources
j r Alan W. Klimek, P. E., Director
'I Division of Water Quality
Q Y
October 1, 2004 RECEIVED
Hubbard Baker N. G. f ''''" Df EH N R
Raker Farm 0 C T 15 2004
3113 Marlboro Church Road
Sophia NC 27350 Wsnst.o ,- Salf'l'1"l
R Mona! Office
Subject: Certificate of Coverage o. AWS7G0010
Baker farm
Swine Waste Collection, Trcattrtent,
Storage and Application System
Randolph County
Dear Hubbard Baker:
On June 11, 2004, the North Carolina Division of Water Quality (Division) issued a revised State General
Permit for swine facilities. The General Permit was issued in accordance with the directive of Senate Bill
733 (Session Law 2003-28).
In accordance with your application received on February 20, 2003 and in accordance with the directive
of Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to
Hubbard Baker, authorizing the operation of the subject animal waste collection, treatment, storage and
land application system in accordance with General Permit AWG100000. The issuance of this COC
supercedcs and terminates your previous COC Number AWS760010 which expires October 1, 2004.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste front the Baker Farm, located in Randolph County, with an animal capacity of no greater
than an Annual average of 1900 Fceder to Finish swine and the application to land as specified in the
facility's Certified Animal Waste Management Plan (CAWMP). If this is a barrow to Wean or Farrow to
Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary, dhcy may
be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a rate of 4
gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAW M1', and this COC, An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Since this is a revised State
General Permit, it contains new requirements in addition to most of the conditions contained in the
previous State General Permit, Enclosed for your convenience is a package containing the new and
revised forms used for record keeping and reporting. Please pay careful attention to the record -keeping
and monitoring conditions in this permit.
Aquifer Protection Section - Animal Feeding Operations Unit
1636 Mail Service Center, Raleigh, North Carolina 27699-1638
Phone: [phone] FAX: [phone] Internet: h2o.enr.state.nc,us
An Equal OpportunitylAffirmative Action Employer-50%a Recycled/10% Post Consumer Paper
One
North Carol ina
�lltlll ally

If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilisation Plan is
inaccurate you.w°ill need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Perntittce from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Perinittee must submit
documentation to the Division demonstrating that all current MRCS standards are mct prior to restocking
of the facility.
Per 15A NCAC 21-1 .0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100 foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this CDC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
Genera] Permit, all application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A nanielownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC_ are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Winston-Salem Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Duane Leith at [phone].
Sincerely,
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
Winston-Salem Regional ❑ffice, Aquifer Protection Section
Randolph County Health Department
Randolph County Soil and Water Conservation District
Permit File A W S7600 f 0
APS Central Files

Al,1S-7(aeafa
Nutrient Management Plan For Animal Waste Utilization
This plan has been prepared for:
Baker Farms
Hubbard Baker
3113 Marlboro Church Rd
Sophia, NC 27350
336-498-3973
1.1-20-2006
This plan has been developed by:
Randy Blackwood
USDA! -NR CS
Asheboro Field Office
241 Sunset Avenue
Suite 105, Fed, Bldg=.
Asheboro, NC 27203
(3 ) 629-4449 Zj
Developer Signature -
Type of Plan: Nutrient Management «vith Manure Only
RE:CEIVEq
N.C. C}api, of 1-NR
APR 0 2 2009 J�
Winslon-Saleori f
Regional Qfroce ffffffff
Owner/Manager/Producer Agreement
I (we) understand and agree to the specifications and the operation and maintenance procedures
established in this nutrient management plan which includes an animal waste utilization plan for
the farm named above. I have read and understand the Required Specifications concerning anima]
waste management that are included with this plan.
Signature (owner) Date
Signature (manager or producer) Date
This plan meets -the minimum standards and specifications of the U.S. Department of Agriculture -
i\atural Resources Consen-ation Service or the standard of practices adopted by the Soil and Water
Conservation Commission.
9
Plan Approved By:9,17NY'l �
Technical Specialist Signature Da
.....................••------.........................--........_............. .......................... ........................... --
971652 Database Version 11 Date Printed: 11-20-2006 Cover Page 1

Nutrients applied in accordance with this plan will be supplied from the following
source(s):
Commercial Fertilizer is not included in this plan.
S7
Swine Feeder -Finish Lagoon Liquid waste generated 1,761,300 gals/year by a 1,900
animal Swine Finishing Lagoon Liquid operation. This production facility has waste
storage capacities of approximately 180 days.
Estimated Pounds of Plant Available Nitrogen Generated per Year
Broadcast
4057
Incorporated
6967
Injected
7672
Irrigated
4409
Max. Avail.
PAN (ibs) *
Actual PAN
Applied (lbs)
PAN Surplus/
Deficit (lbs)
Actual Volume
Applied (Gallons)
Volume Surplus/
Deficit (Gallons)
Year 1
4,409
6300
-1,891
2,516,654
-755,354
----------------------------------------------------------------------------------- -- ---- - sour e.
Note: ]n source II7, S means standard source, U means user defined source.
* Max. Available PAN is calculated on the basis of tho actual application method(s) identified in the plan for this source.
971652 Database Version 3.1 Date Printed: 11-20-2006 Source Page Page l of 1

Na rrative
PLAT run Sept. 2006. Entire CNMI' re -written to incorporate PLAT as well as addition of land owned
by Curtis Redding. Pulls 8, 9, 10, 11 on Redding property in established fescue pasture. Need to review
wettable acres with Gra-Mac and verify available acres and wettable acres concur.
All acres/useable acres derived from Gra-Mac calculation sheet.
..................... -------------------------------------------...................................... ...................... ..........
971652 Database Version 3.1 Datc Printed: 1 1-20-2006 Narrative Page Page 1 of 1

The table shown below provides a summary of the crops or rotations included in this plan for each field. Realistic Yield estimates are
also provided for each crop, as well as the crop's P205 Removal Rate. The Leaching Index (LI) and the Phosphorous Loss Assessment
Tool (PLAT) Rating are also provided for each field, where available.
If a field's PLAT Rating is High, any planned manure application is limited to the phosphorous removal rate of the harvested plant
biomass for the crop rotation or multiple years in the crop sequence. Fields with a Very I ligh PLAT Rating should receive no
additional applications of manure. Regardless of the PLAT rating, starter fertilizers may be recommended in accordance with North
Carolina State University guidelines or recommendations. The quantity of P205 applied to each crop is shown in the following table if
the field's PLAT rating is High or Very High.
Planned Crops Summary
Tract
Field
Total
Acres
Useable
Acres
Plat
Rating
LI
Soil Series
Crop Sequence
RYE
P205
RemovalApplied
(lbs/acre)
(lbslacre)
1433
2-10
J 7.26
7.26
Low
ILIA
Wynoti
Fescue Pasture
3.5 Tons
6
NIA
1433
2-1 I
y 5.0
5.00
Low
I NIA
Wynott
Fescue Pasture
3.5 Tons
6
NIA
1433
2-8
1 5.00
5.00
Law
NIA
Mecklenburg
Fescue Pasture
3.9 Tons
6
NIA
1433
2-9
5.00
5.00
Low
NIA
Mecklenburg
Fescue Pasture
3.9 Tons
6
N/A
1470
1-]a
1.98
1.98
Low
NIA
Mecklenburg
Common BermudaWass Hay
3.5 Tons
42
NIA
1470
1-lh
I.00
1.00
Low
NIA
Mecklenhurg
Common 13crtnudagrass Hay
3.5 Toils
42
NIA
1470
1-2a
i 2.50
2.50
Low
NIA
Mecklenhurg
Common Bermudagrass Hay
3.3 Tons
40
NIA
1470
1-2b
J 1.01
1.01
Low
NIA
Wvnott
Common Bermudagrass IIay
23 Tons
28
NIA
1470
1-2c
J 2.52
2.52
Low
NIA
Wynott
Common Bermudagrass Flay
2.3 Tons
28
NIA
1470
2-3
13,20
3.20
Low
NIA
Mecklenburg
Mixed Cool Season Grass -Hay
2.8 Tons
40
NIA
1470
2-4
f 4.43
4.43
Low
NIA
1G'ynott
Mixed Cool Season Grass -Hay
2.4 Tans
34
NIA
1470
3-5
5 99
5.99
Low
N/A
Badin
Mixed Cool Season Grass -Hay
2.2 Tons
31
NIA
1470
3-6
4.58
4.58
Low
NIA
Badin
Mixed Cool Season Grass-1 lay
2.2 Toils
31
NIA
1470
3-7
5.28
5.28
Low I
NIA I
Badin
Mixed Cool Season Grass -Hay
22 Tons
31
NIA
PLAN TOTALS: 54.75 54.75
971652 Database Version 3.1 Date Printed 11/20i2006
PCS Page Page 1 of 2
NOTE: Symbol . means user entered data.

LI
Potential Leaching
Technical Guidance
Low potential to contribute to soluble
None
C 2
nutrient leaching below the root zone.
>_ 2 &
Moderate potential to contribute to soluble
Nutrient Management (590) should be planned.
nutrient leaching below the root zone.
�= 10
High potential to contribute to soluble
Nutrient Management (590) should be planned. Other conservation practices that improve the soils
uttient leaching below the root zone,
available water holding capacity and improve nutrient use efficiency should be considered. Examples
> 10
are Cover Crops (340) to scavenge nutrients, Sod -Based 11otations (328), Long- berm No= fill (778),
and edge -of -field practices such as Filter Strips (393) and Riparian Forest Buffers (391}.
PLAT Index
Rating
P Mana'geinent Recommendation
0 - 25
I.ow
No adjustment needed; N based application
25 - 50
Medium
No adjustment needed; N based application
51 - 100
1ligh
Application limited to crop ?removal
> 100
Very High
Starer P application only
971652 Database Version 3.1 Date Printed 11/20/2006
PCS Page Page 2 of 2
NOTE: Symbol * means user entered data.

The Waste Utili7ttion table shown below summarizes the waste utilization plan for this operation. This plan provides an estimate of the number of acres of cropland needed to use
the nutrients being produced, The plan requires consideration of the realistic yields of the crops to be grown, their nutrient requirements, and proper timing ofapplications to
maximize nutrient uptake.
This table provides an estimate of the amount of nitrogen required by the crop being grown and an estimate of the nitrogen amount being supplied by manure or other by-products,
commercial fertilizer and residual from previous crops. An estimate of the quantity of solid and liquid waste that will be applied on each field in order to supply the indicated quantity "
of nitrogen from each source is also included. A balance of the total manure produced and the total manure applied is included in the table to ensure that the plan adequately provides
for the utilization of the manure generated by the operation.
Waste Utilization Table
Year 1
Tract
Field
Soutee
1D
Soil Series
Total
Acres
Use,
Acres
Crop
RYE
Applic.
Period
Nitrogen
PA
Nutrient
Req'd
(lbs/A)
Comm.
Fert.
Nutrient
Applied
(lbs/A)
Res.
Obs/A)
Applie.
Method
Manure
PA
NutrientA
pplied
pbs1A)
Liquid
ManureA
pplied
(acre)
Solid
Manure
Applied
(acre)
Liquid
Manure
Applied
(Field)
Solid
Manure
Applied
(Field)
N
N
N
N
1000
gal/A
Tots
]0p0 gals
tons
1433
2-10
57
Wynott
7,26
7.26
Fescue Pasture
3.5 Tons
8/1-7/31
117
0
0
]rrig.
117
46.74
0.00
339,29
0.00
1433
2-11
57
Wynott
5.00
5.00
Fescue Pasture
3.5 Tons
8/1-7/31
117
0
0
brig.
117
46.74
0.00
233.67
0,00
1433
2-8
S7
Mecklenburg
5,00
5.00
Fescue Pasture
3.9 Tons
811-7131
130
0
0
trig.
130
51.93
0.00
259.64
0.00
1433
2-9
S7
Mecklenburg
5,00
5.00
Fescue Pasture
3.9 Tons
8/1-7/31
130
0
0
]Frig.
130
51,93
0.00
259,64
0,00
1470
1-la
57
Mecklenburg
1.98
1.98
Common Bermudagrass Hay
3.5 Tons
3115-9115
155
0
0
]rrig.
1551
61.91
0.00
122,59
0.00
1470
]-lb
S7
IMecklenburg
1,00
1.00
Common Bermudagrass Hay
3.5 Tons
3/15-9/15
155
0
0
]rrig,
155
61.91
0-001
61.91
0.00
1470
1-2a
S7
Mecklenburg
2.50
2.50
Common Bermudagrass Hay
3.3 Torts
3115-9115
147
0
0
Irrig.
147
58.72
0.00
146.80
0.00
1470
1-2b
S7
Wynott
1,01
1,01
Common Bermudagrass Hay
2.3 Tons
3/15-9115
102
0
0
[rrig.
102
40.74
0.00
41.15
0.0[}
1470
1-2c
57
Warnott
2.52
2.52
Common Bermudagrass Hay
2.3 Tons
3/15-9/15
102
0
0
brig.
102
40,741
0,00
102.67
O.G
1470
2-3
S7
Mecklenburg
3.20
3.20
Mixed Cool Season Grass -Hay
2.8 Tans
8/1-7/31
124'
0
0
[rrig.
124
49,53
0,001
158.50
0.00
1470
2-4
S7
Wynott
4.43
4.43
Mixed Coal Season Grass -Hay
2.4 Tons
8/1-7/31
107
0
0
]rrig.
10
42,74
0.00
189,34
0.00
1470
3-5
S7
Badin
5.99
5.99
Mixed Cool Season Grass -Hay
2.2'rons
8/1-7/31
95
0
0
]frig-
95
37.95
0.00
227.30
0.00
1470
3-6
S7
Badin
4.59
4.58
Mixed Cool Season Grass -Hay
2.2 "Pons
811-7/31
95
0
0
[rrig.
951
37.95
0.00
173.80
3-7
S7
Badin5.28
5.28
Mixed Cool Season Grass -Hay
2.2 Tons
811-7/31
95
0
0
[rrig.
95
37.95
0.00200,36
JO.OiD1474
971652 Database Version 3.1 Date Printed: 1 1/20/2006 NNUF Page Page 1 of 2

Waste Utilixalion Table
Year 1
Nitrogen
Comm.
Res,
Mamie
Liquid
Solid
Liquid
Solid
PA
Fert.
OWA)
PA
ManureA
Manure
Manure
Manure
Nutrient
Nutrient
NutritntA
pplied
Applied
Applied
Applied
Req'd
Applied
pplied
(acre)
(acre)
(Field)
(Field)
(lbalA)
(lbs1A)
QWA)
Source
Total
Use.
Applic.
Applic.
I000
Tract
Field
ID
Soil Series
Acres
Acres
Crop
RYE
Period
i
ti
S
Method
ti
gaIJA
Tons
IODO gals
tans
Total Applied, 1000 gallons
2,516.65
Total Produced, ION gal Ions
1,761.30
;
Balance, 1000 gallons
-755.35
Total Applied, tons
' , ti
0.00
Total Produced, to
wj {' y
1000
Balance, tons
Notes: 1. In the tract column, -- symbol means leased, otherwise, owned. 2. Symbol * means user entered data-
971652 Database Version 3.1 Date Printed: 1 U2612006 WUT Page Page 2 of 2

The Irrigation Application Factors for each field in this plan are shown in the following table. Infiltration rate varies with soils. If
applying waste nutrients through an irrigation system, you must apply at a rate that will not result in runoff, This table provides the
maximutn application rate per hour that may be applied to each field selected to receive wastewater. It also lists the maximum
application amount that each field may receive in any one application event.
Irrigation Application Factors
Tract
Field
Soil Series
Application Rate
(inches/hour)
Application Amount
(inches)
1433
2-10
Wynott
0.30
1.0
1433
2-11
Wynott
0.30
1.0
1433
2-8
Mecklenburg
0.30
1.0
1433
2-9
Mecklenburg
0.30
1.0
1470
I -la
Mecklenburg
0.30
1.0
1470
1-lb
Mecklenburg
0.30
1.0
1470
1-2a
Mecklenburg
0.30
1.0
1470
1-2b
Wynott
0.30
1.0
1470
1-2c
Wynott
0.30
1.0
1470
2-3
Mecklenburg
0.30
1.0
1470
2-4
Wvnott
0.30
1.0
1470
3-5
Badin
0.30
1.0
1470
3-6
Badin
0.30
1.0
1470
3-7
Badin
0.30
1.0
971652 Database Version 3.1 Date Printed 1 1/20/2006 1AF Page Page I of I
NOTE Symbol " means user entered data.

The Nutrient Management Recommendations table shown below provides an annual summary of the nutrient management plan
developed for this operation. This table provides a nutrient balance for the listed fields and crops for each year of the plan.
Required nutrients are based on the realistic yields of the crops to be grown, their nutrient requirements and soil test results. The
quantity of nutrient supplied by each source is also identified.
The total quantity of nitrogen applied to each crop should not exceed the required amount. IIowever, the quantity of other
nutrients applied may exceed their required amounts. This most commonly occurs when manure or other byproducts are utilized
to meet the nitrogen needs of the crop. Nutrient management plans may require that the application of animal waste be limited so
as to prevent over application of phosphorous when excessive levels of this nutrient are detected in afield. In such situations,
additional nitrogen applications from nonorganic sources may be required to supply the recommended amounts of nitrogen.
Nutrient Management Recommendations Test
YEAR
1
N
(1bs1A)
11205
(lbs1A)
K2O
(lbs1A)
Mg
(lbs1A)
Mn
(1bs/A)
Zn
(Ibs1A)
Cu
(lbs1A)
Limc
(tonslA)
Tract
Field
1433
2-10
Req'd Nutrients
117
0
0
0
0
0
0
2
Acres A . Period
7.26
811-7131
Supplied B�;^
',Z�!7 -
[•, p:'..i s :
i `'
:a
i
w e •:
'
CROP
Fescue Pasture
Starter
0
0
0
0
0
0
0
0
Commercial Fen.
0
0
0
0
0
0
0
0
Soil Series
Wynott
Residual
0
0
0
0
0
0
0
0
RYE I Sample
Dille
3.5 Tons
10-07-05
Manure
117
64
160
14
1
3
1
0
P Removal
Rating
6 lbslac.
Low
13AIANC17
01
64
1601
14
1
3
1
2
Tract Field
1433
2.11
Req'd Nutrients
117
0
0
0
0
0
0
2
Acres
A Period
PP-
5.00
811.7131
5uppliedBy:
.:yam:
�.�;. *'
,err
i' i f•, i.,
•.s. ±
t y it
' N
ro,• :,,
�.9?;.s%;ti it
S•;.
CROP
Fescue Pasture
Starter
0
0
0
0
0
0
0
0
Commercial Fert.
0
0
0
0
0
0
0
0
Soil Series
Wynott
Residual
0
0
4
0
0
0
0
0
RYE Sample
Bate
3.5 Tons
10-07-05
Manure
117
64
160
14
1
3
1
0
P Removal
Rating
6 lbslac,
Low
BALANCE
0
64
160
14
1
31
1
•2
Tract
Field
1433
2-8
Req'd Nutrients
130
0
0
0
0
0
0
2
Acres
Am Period
IMP' e
5-00
/�
$Il-7 1
!a
SuppkiedBy:
_; ''++`•!' '"
?1:u.:;4
;.c>'�� a:.;,
,T: 4. 5..
: + ;�.
1 :h C:e..ax
.i,.--
• rr
i:l,.t
l t;:�4
N
.tiS.•�•'
•�••�;:-
.i:'?.� '�ii:t
i'" r,~
r� N"�:�-i':.?}
�u; i • t,
4S Ff-I.i:.
CROP
fescue Pasture
Starter
0
0
0
0
0
0
0
0
Commercial Fert-
0
0
0
0
0
0
0
0
Soil Series
Mecklenburg
Residual
0
0
0
0
0
0
0
0
RYE I Sample
date
3.9 Tons
10-07-05
,Manure
130
71
178
16
1
3
1
0
P Removal Rating
6 lbslac,
Low
BALANCE
0
71
178
16
1
3
1
-2
Tract
Field
1433
2-9
Req'd Nutrients
00
0
0
0
0
0
0
2
Acres
App. Period
5-00
811-7/3)
Supplied By:
n. f
: �.
ni : �'
r3'
ES_
• ;:. 4 ';�
1, tidT;' :.[
.'� 5•`�s` zl.�:`
CROP
Fescue Pasture
Starter
0
0
0
0
0
0
0
fl
Commercial Fert.
0
0
0
0
0
0
0
0
Soil Series
Mecklenburg
Residual
0
0
0
0
0
0
0
4
RYE Sample
Date
3.9 Tons
10-07-05
Manure
130
71
178
16
1
3
1
Il
P Removal
Rating 1
6 lbslac, 1Low
BALANCE
0
71
178
16
11
31
1
-2
971652 Dalabase Version 3.1 Date Printed: 11/20/2006 NMR Page Page 1 of 3

Nutrient Management Recommendations Test
YEAR
1
N
(lbs/A)
P205
(lbs/A)
K20
(lbs/A)
Mg
(lbs/A)
Mn
(lbs/A)
Zn
(lbs/A)
Cu
(lbs/A)
Lime
(tons/A)
Tract
Field
1470
]-]a
Req'd Nutrients
155
90
0
a
0
0
0
1
Acres
App. Period
1.98
3/15-9/15
Supplied By:
CROP
Common Fict-rmidagTass
Hay
Starter
0
0
0
0
0
0
0
0
Commercial Fert.
0
0
0
a
0
0
0
0
Soil Series
Mecklenburg
Residual
0
0
0
0
0
0
0
0
RYRI Sample
Date
3,5 Tons
10-07.05
Manure
1551
94
212
19
1
41
1
0
P Removal
Rating
42 lbs/ac.
Low
BALANCE
0
.6
212
19
1
4
1
-1
Tract:
I
Field
1470
I -lb
Req'd Nutrients
155
90
0
0
0
0
0
M
1
Acres I
App. Period
1.00
3/15-9/15
Supplied By::
_..,
114L
t t
—
-
7
CROP
Common Bermudagrass
Hay
Starter
0
0
0
0
0
0
0
0
Commercial Fert.
0
0
0
0
0
0
0
0
Soil Series
Mecklenburg
Residual
0
0
0
0
0
0
0
0
RYEJ Sample
Date
IS Tons
10-07.05
Manure
155
84
212
19
1
4
1
0
P Removal
Rating
42 lbs/ac.
Low
13AIkNCF
0
-6
212,
19
1
4
1
-1
Tract
Field
1470
1-2a
Rrq'd Nutrients
147
90
0
0
0
0
0
1
Acres App. Period
2.50
3115-9/15
Supplied By
.
v � .?
CROP
Common Bcrmudagrass
Hay
Starter
0
a
0
0
0
0i
0
0
Commercial Fen-
0
0
0
0
0
0 1
0
0
Soil Series
Mecklenburg
Residual
0
0
0
0
0
0
0
0
AYEJ Sample
Date
3-3 Tons
10-07-05
Manure
147
80
201
is
1
3
1
0,
P Removal
Rating
4 0 1 Usl c.
Low
BALANCE
0
-10
201
18
1
3
1
Tract
Field
1470
1-2b
Rcq'd Nutiien Is
102.
90
0
0
0i
D
0
Acres
App, Period
1-01
3115-9115
Supplied By:
CROP
Common Bermudagrass
Hay
Starter
0
0
0
0
0
0
0
0
Commercial Fert.
0
0
0
0
0
0
0
0
Soil Series
Wynott
Residual
0
0
0
0
0
0
0
0
AYE I Sample
Date
2.3 Tons
10-07-05
Manure
102
56
140
121
1
2
fl
0
P Removal
I Rating
28 lbs,/ac.
Low
BALANCE
0
-34
140
12
1
2
0
1
Tract
I Field
1470
1-2c
Rcq'd Nutrients
102
90
0
0
0
0
0
1
Acres
App- Period
252
3/15-9/15
Supplied By:
14
CROP
Common Bermudagrass
f I ay
Starter
01
0
0
0
0
0
01
0
Commercial Fert.
0
0
0
0
0
0
0
0
Soil Series
Wynott
Residual
0
0
0
0
0
0
0
0
MRYB
le Date
2.3 Tons
10-07-05
Manure
102
56
)40
12
1
2
0
0
Rating
28 IbYac- I
Low I
BALANCE
0
-34 I
1401
12
11
21
0
_-11
971652 Database Version 3.1 Datellrinted, 11/20/2006 NMR Page Page 2 of 3

Nutrient Management Recommendations Test
YEAR
j
N'
(ibs1A)
P2O5
(lbs1A)
K20
(ibs1A)
Mg
(1bs1A)
Mn
(lbs1A)
Zn
(lbs1A)
Cu
(lbs1A)
lime
(tons/A)
Tract
Field
1470
2-3
Req'd i Nutrients
124
90
0
0
0
0
0
0
Acres
App. Period
3.20
811-7131
Supplied By:
y #-0.f
; r -
i; ;- ._+
f *;
'e:`e
CRDp
Mixed Coal Season
Grass -Hay
Starter
0
0
0
0
0
0
0
0
Commercial Fert.
0
0
0
0
0
0
0
0
Soil Series
Mecklenburg .
Residual
0
0
0
0
0
01
0
0
RYE I Sample
Date
2.8 Tons
10-07-05
Manure
124
68
170
15
1
3
1
0
P Removal
I Razing
40 lbslac,
Low
BAL.ANCk
0
-22
..1701
15
1
3
1
0
Tract
Field
1,170
2-4
Req'd Nutrients
107
90
0
0
4
0
0
[}
Acres I
App- Period
4-43
811-7131
Supplied B
i;d =
.`" 7:
yam`,
r
K..E.S, ,V
,..
t' 1�3 +': ;';
CROP
Mixed Cool Season
Grass -Hay
Starter
0
0
0
0
0
0
0
0
Commercial Fen.
0
0
0
0
0
0
0
0
Soil Series
'Wynott
Residual
0
0
0
0
0
0
0
0
RYE Sample
Date
2.4 Tons
10-07-05
Manure
107
58
147
13
1
2
0
0
PRemoval Rating
34lbstac.
Low
BALANCE
0
•32
147
•13
1
21
0
0
Tract
Field
1470
3-5
Req'd Nutrients
95
110
0
0
0
0
0
0
Acres
App. Period
5.99
811-7131
Supplied By,
rrt"sF1'i -..�'^
tx. ,L f rr�
�...fi [��. 2',.
K;.ia r:r - -
ni.i
_:x • ^1i
:+1:.
i 3.t i':
•,'�' f;ry._k..6
' . rt-:
'ti: e. �
z a".1 :'�T
1F!":�..�.• �i
Y d +�?,'#.
�iif: ;'":i ..91.:.Stia:
CROP
Mixed Cool Season
Grass -Hay
Starter
0
0
0
0
0
0
0
0
Commercial Fert.
0
0
0
0
0
0
0
0
Soil Series
Badin
Residual
0
0
0
0
0
{N
0
0
RYI; I Sample
Date
2-2 Tons
10-07-05
Manure
95
52
130
12
0
2
0
0
1' Rem ova!
I Rating
31 lbslac.
Low
BALANCE
0
-58
130
12
0
2
0
0
Tract
Field
1470
3-6
Req'd Nutrients
95
110
0
0
0
0
0
0
APP. Period
4.58
811-713]
Supplied $
;Acres
n. t
e rfi`i..:'.:
r. c.. . ,.ti
c'•; j:tir. r
r• nr t r re:
'wi
s. •.:r.. J. ,:.; • �>
`.� .}.
CROP
Mixed Cool Season
Grass -Hay
Starter
0
0
0
0
0
0
0
0
Commercial Fert.
0
0
0
0
0
U
0
U
Soil Series
Badin
Residual
0
0
0
0
0
01
0
0
RYE I Sample
Date
2.2 Tons
10-07-05
,Manure
95
52
I30
12
0
2
f1
0
P Removal
Rating
31 lbslac.
Low
BALANCE
0
-58
130
12
0
2
0
0
Tract Field
1470
3-7
Rcq'd Nutrients
95
110
0
0
0
0
{]
0
Acres
App Period
5-28
811-7131
Supplied By:,.'.:
a..14 ::i`
CROP
Mixed Cool Season
Grass -Hay
Starter
0
0
0
0
0
0
0
0
Commercial Fert.
0
0
0
0
0
0
0
0
Soil Series
Badin
Residual
01
0
01
0
0
0
0
0
RYE I Sample
Date
2.2 Tons
10-07-05
- Manure
95
52
130
12
0
2
0
0
P Removal
Rating
31 lbslac-
Low
BALA; NCC
0
-58
13Q
12
0
2
0
0
NOTE: Symbol • means user entered data.
971652 Database Version 3A Date Printed; 11/20/2006 NMR Page Page 3 of 3

'rhe Required Soil Test Values shown in the following table provide a summary of recommended actions that should be taken if soil tests indicate excessive levels of
copper or zinc. Fields that receive manure must have an annual soil analysis for these elements. High levels of zinc and copper can adversely affect plant growth.
Alternative crop sites must be used when the concentration of these metals approach excessive levels. Site life can be estimated by dividing the amount of copper and
zinc to be applied in lbslacre by 0.036 and 0.071, respectively and multiplying the result by 0.85. By adding this quantity to the current soil index for copper or zinc, we
can predict life of the site for waste disposal.
In addition to copper and zinc indices, this table also provides a summary of lime recommendations for each crop based on the most recent soil sample. Application of
lime at recommended rates is necessary to maintain soil pH in the optimum range for crop production .
Required Soil 'Pest Values
Tract
Field
Crop
pH
Lime Return.
(tons/acre)
Cu-I
Copper Recommendation
Zn-I
Zinc Recommendation
1433
2-10
Fescue Pasture
4.9
1-9
27
None
log
None
1433
2-11
Fescue Pasture
4.9
1-9
27
None
log
None
W3
2-8
Fescue Pasture
4.9
1,91
27
None
109
None
1433
2-9
Fescue Pasture
4.9
1.9
27
None
109
None
1470
$-la
Common Bermudagrass Flay
6.0
1.I
258
None
172
None
1470
1-lb
Common Bermudagrass Hay
6.0
1.1
258
None
172
None
1470
1-2a
Common Bermudagrass flay
6.0
1.I
258
None
172
None
1470
1.2b
Common Bermudagrass Hay
6-0
1.1
258
None
172
None
1470
1-2c
Common Bermudagrass Flay
6.0
1.1
258
None
172
None
1470
2-3
Mixed Coo$ Season Grass -Hay
6-0
00
258
None
172
None
1470
24
Mixed Cool Season Grass -Hay
6.0
0-0
258
None
172
None
1470
3-5
Mixed Cool Season Grass -Hay
6.7
0.0
188
None
114
None
1470
3-6
Mixed Cool Season Grass -liar•
6-7
0.01
188
None
114
None
1470
1 3-7
Mixed Cool Season Grass -Flay
6.7
0.01
188
1 None
114
None
. -------------------•------------------- .------- ...------- ._--------------------- ..------- . .......................---................
971652 Database Version 3.1 Date Printed: 1 i-20-2006 STV Page Page I of 1

The following Lagoon Sludge nitrogen Utih7ation table provides an estimate of the number of acres needed for sludge
utilization for the indicated accumulation period. These estimates are based on average nitrogen concentrations for each source,
the number of animals in the facility and the plant available nitrogen application rates shown in the second column.
Lagoon sludge contains nutrients and organic matter remaining after treatment and application of the effluent. At clean out, this
material must be utilized for crop production and applied at agronomic rates. In most cases, the priority nutrient is nitrogen but
other nutrients including phosphorous, copper and zinc can also be limiting. Since nutrient levels are generally very high,
application of sludge must be carefully applied.
Sites must first be evaluated for their suitability for sludge application. Ideally, effluent spray fields should not be used for
sludge application. If this is not possible, care should be taken not to load effluent application fields with high amounts of
copper and zinc so that additional effluent cannot be applied. On sites vulnerable to surface water moving to streams and lakes,
phosphorous is a concern. Soils containing very high phosphorous levels may also be a concern.
Lagoon Sludge Nitrogen Utilization Table
Crop
Maximum
PA-N Rate
lblac
Maximum Sludge
Application Rate
1000 gallac
Minimum Acres
5 Years Accumulation
Minimum Acres
10 Years Accumulation
Minimum Acres
15 Years Accumulation
Swine feeder -finish Lagoon Sludge - Standard
Com I20 bu
150
13.16
23.82
47.64
71.46
Hay 6 ton R.Y.F.,
300
26.32
11.91
23.82
35.73
Soybean 40 bu
160
14.04
22.33
44.66
66.99
------------- -------------------------- ........ . ...... ........................ ................. ...................... ....------------- ..-.----------------------------------- ...-
971652 Database Version 3.1 Date Printed: 1 1-20-2006 Sludge Page Page 1 of

The Available Waste Storage Capacity table provides an estimate of the number of days of storage capacity available
at the end of each month of the plan. Available storage capacity is calculated as the design storage capacity in days
minus the number of days of net storage volume accumulated. The start date is a value entered by the user and is
defined as the date prior to applying nutrients to the first crop in the plan at which storage volume in the lagoon or
holding pond is equal to zero.
Available storage capacity should be greater than or equal to zero and less than or equal to the design storage
capacity of the facility. If the available storage capacity is greater than the design storage capacity, this indicates that
the plan calls for the application of nutrients that have not yet accumulated. If available storage capacity is negative,
the estimated volume of accumulated waste exceeds the design storage volume of the structure. Either of these
situations indicates that the planned application interval in the waste utilization plan is inconsistent with the
structure's temporary storage capacity.
Available Waste Storage Capacity
Source Name Swine Feeder -Finish Lagoon Liquid
Design Storage Capacity (Days)
Start Date 4/30
180
Plan Year
Month
Available Storage Capacity (Days) •
1
1
116
1
2
180
1
3
180
1
4
150
1
5
139
l
6
139
1
7
128
i
8
172
1
9
180
1
10
180
1
11
170
1
12
139
Available Storage Capacity is calculated as of the end of each month.
.................................................................................................................................................................
971652 Database Version 3.1 Date Printed: 11-20-2006 Capacity Page Page 1 of 1

Operator: Hubbard Baker Conservation Plan Map
0-wner: same Map Use: Location
Ratzdolph, NC - SWCD
Farm �� Tract(s) - 1470 1 inch equals 8,000 feet
0 4,000 9,000
a, Feet
%0�
u
Prepared wig aui:once Trum
N RCS
LLJ co D
I - L 1
m z
A NER HiTEHEAO R c!N
0
S' RQLPni
m ROY FA
W RO 0 O �,, PLK r K VIEW
EpG, ' 44 r a RQ
w
L N
Q-
d
�
L flN O�FP E O NAO �u
,c Rp �y
G
•
... r
•
�7fr
■
� .
■
�
rI
OR
IN
�■■calf#iN��a�ti�j�.
���

Operator: Hubbard Baker
Owner: same
Randolph, NC - Sit -CD
�
FaA 7Tract(s) - ] 470
Conservation Plan Map
Map Use: Nutrient Management
1 inch equals 400 fee!
0 200 400
Feet
v tiLU
Y
co
Tw
.,
- - 4 A L7 ac
? 3V,9 ac
is } v.� a 'j 7 +�r"ti.-'► +�_a, yt'~ �ti i' Mti• y �ti
a ;y7-� J 1�'r �F���� '••�y�A+a-'• 'r'-ski
f: f
ti :'.� • y .V�.wNri wy�" ry;: wz+ �'4`,,r i.yr
J '� J :r � ::r' ' s` t � s�''.�: ".- •iy L - ac :fro'.
p N
' ytij .~� ^y •Y' :�'W Y�i wpm t�w� - ei VFW,'
�H
rm LA l q-70
P�"f-w with 1"U: from-
t N RCS
McC2 Jk WV$2
McC2
Mac
WPC
— Roads
C3Soils
— Streams
Reid Types
Fields
CSforestland
": hayland
C3 headquarters
M lagoon
pastureland
Line Features
Lines
- irrigation pull

Operator: Hubbard Baker
Owner: same
Raradnlph, NC - SIM)
l-arm'{;1Trac1(s) - 1470
t
. Mr'i �'� f •.:
Sw;i•:h r��.Y�
Jlq's
Fr, :3(4
it; 4, ,
n
i
Conservation Plan Map
Map Use: h'utriert Management
1 inch cquals 400 feet
0 200 400
Feet
L .t,�R�yir ��3�•✓r-i�-i ,��. 'Y �f i7�"
■
A.
r�►. °kr'
s. Q
3o ri''- 4ac U ;1:.
ne
el 10 `rY
417
~j I. + i $a�,,��,'F��'�j•'��' 1.M�.��ir�4y,44A.
ti
S
PFC"Md Willi us s:stanc lr011 L'
%6w N RCS
�; �f:,{� ,.., gip•: 4� � ` ,
7Ao
,
V.'� ��zih"ii•i�ii's'"of
x�o
'tT
;. !CIF, {F" Y „,?7� •? �i; f�! 'tiro •A�;d:
�� �4 ��''' ry.,1■ r�� -•,.:.;... �� •4 ti ,.,' �+-' sue- rA��.?L":ess Sri
1.; AQ Y s►yK + . ;_3;,bY" �,,,� >+ , r:.rt . 4bt
61
y ` . * ' ': '7�•�.}. ,�., S, .
j. �. �. kraC .°�" qlt 4�}:U tin•.v T.17 q
art., x§• 1 ,� ,Yrr .li' •r +. *L.4 r^ ` i6�r,�
��, �;�a' ..'��. '`26.8 c•;z... _ . • �`�^.��'��` k is
7Jik 7k' '�.,TF•�,, -.R_ y p^.af r !^d$�I� # 1]
��i�, ��nrk+:�"� ' : a•' k..,Z' 1y ..'r,�..t,�i'�� . 99„ �i" � •�.'"`�'nr.�l `�7 � y'�1 ;�••�'"
rf't 4 y •�i '. ' •S� Gtal-•� 4 ; aC n!TraG+G
S al•.•tl <S':,si r.'+aaoeo�oan' • r ice. M1
Ov
i ��:. tx a iT ►:. 4��v } . .
y. P• •.. • b+x� /.. '�Y. 74'f'�''�i :. ".1L. � �L q9.7 �,rr �'� l � r tii �.r�:,. 1 E
i' „".7.: iS ..,.�'••Si'aa•. 7i i.k �} .' Y,` .lY..: 1']_15. JI_�t' �, i
RH�f ��s�n't?mcwot�ooe u w`pVfR k�a¢�caemo5 L �i�~•�e. T� i�tii 1.
i?" r � •i-•i'�',�:.�p�•r y. .Y'ti.�.r�� y.��.`'C'+ sF"�7 t'l/yS� �r
�� �•C•-: t`•w`�,�a}','�F•:... �':� i�lV Q +d(i'..
ti��M1 :++,���. �'^� i�ii�}'+'�'��u�•-`�'��j7�..�•,:Y',j''ex �`^�isR`•''�. r`�'
�Wtr'�'�4b��,,Yv;�•'Y�'
'71•' `K',�;•,+" '� *•,fit r'•7 `*'.-x!�r 1F •at;'a••.��j'�'}� iJ':. iX
e�� y61y�r�17 y� w-'I •1; i` •trk �:• ytT �.. ��L. �. } s , ir' �.
if i�•,y I�~ 1�^'+� ' y,T• t r �'.�3.Y.�i.yr•$�5iwF7�F iKikT� .L �' �'.t�1'�.��t
`.Ta. 1 : f�h` "1 A'•1• h Soli <i1
�rd'r: ��:.,:'• a,r+y' � t f K* ----'Roads
s 4" '�'. 4'g'a�,� : [■ �'�^ k fit* F.,�... —Streams
'`!�, e.'�i:�t1✓t■�a,%''s �'L.,K. } Fleld Types
'fp'xilii jW
Yp
Fields
C3forestland
fy ;�-:•�'a� Vhayland
.' headquarters
'NFri lagoon
*n �. , � s,••+. 'f ��; ��„�,Y �':i.� :Z pastureland
M1' .
o f s1�'�?,i. c t. r t+•r#'y T.• Line Features
Lines
'I F.Fj, 1R'nw =N7.Y' S�•
, ; r, s�� y,.k; irrigation pull
ti
S
PFC"Md Willi us s:stanc lr011 L'
%6w N RCS
�; �f:,{� ,.., gip•: 4� � ` ,
7Ao
,
V.'� ��zih"ii•i�ii's'"of
x�o
'tT
;. !CIF, {F" Y „,?7� •? �i; f�! 'tiro •A�;d:
�� �4 ��''' ry.,1■ r�� -•,.:.;... �� •4 ti ,.,' �+-' sue- rA��.?L":ess Sri
1.; AQ Y s►yK + . ;_3;,bY" �,,,� >+ , r:.rt . 4bt
61
y ` . * ' ': '7�•�.}. ,�., S, .
j. �. �. kraC .°�" qlt 4�}:U tin•.v T.17 q
art., x§• 1 ,� ,Yrr .li' •r +. *L.4 r^ ` i6�r,�
��, �;�a' ..'��. '`26.8 c•;z... _ . • �`�^.��'��` k is
7Jik 7k' '�.,TF•�,, -.R_ y p^.af r !^d$�I� # 1]
��i�, ��nrk+:�"� ' : a•' k..,Z' 1y ..'r,�..t,�i'�� . 99„ �i" � •�.'"`�'nr.�l `�7 � y'�1 ;�••�'"
rf't 4 y •�i '. ' •S� Gtal-•� 4 ; aC n!TraG+G
S al•.•tl <S':,si r.'+aaoeo�oan' • r ice. M1
Ov
i ��:. tx a iT ►:. 4��v } . .
y. P• •.. • b+x� /.. '�Y. 74'f'�''�i :. ".1L. � �L q9.7 �,rr �'� l � r tii �.r�:,. 1 E
i' „".7.: iS ..,.�'••Si'aa•. 7i i.k �} .' Y,` .lY..: 1']_15. JI_�t' �, i
RH�f ��s�n't?mcwot�ooe u w`pVfR k�a¢�caemo5 L �i�~•�e. T� i�tii 1.
i?" r � •i-•i'�',�:.�p�•r y. .Y'ti.�.r�� y.��.`'C'+ sF"�7 t'l/yS� �r
�� �•C•-: t`•w`�,�a}','�F•:... �':� i�lV Q +d(i'..
ti��M1 :++,���. �'^� i�ii�}'+'�'��u�•-`�'��j7�..�•,:Y',j''ex �`^�isR`•''�. r`�'
�Wtr'�'�4b��,,Yv;�•'Y�'
'71•' `K',�;•,+" '� *•,fit r'•7 `*'.-x!�r 1F •at;'a••.��j'�'}� iJ':. iX
e�� y61y�r�17 y� w-'I •1; i` •trk �:• ytT �.. ��L. �. } s , ir' �.
if i�•,y I�~ 1�^'+� ' y,T• t r �'.�3.Y.�i.yr•$�5iwF7�F iKikT� .L �' �'.t�1'�.��t
`.Ta. 1 : f�h` "1 A'•1• h Soli <i1
�rd'r: ��:.,:'• a,r+y' � t f K* ----'Roads
s 4" '�'. 4'g'a�,� : [■ �'�^ k fit* F.,�... —Streams
'`!�, e.'�i:�t1✓t■�a,%''s �'L.,K. } Fleld Types
'fp'xilii jW
Yp
Fields
C3forestland
fy ;�-:•�'a� Vhayland
.' headquarters
'NFri lagoon
*n �. , � s,••+. 'f ��; ��„�,Y �':i.� :Z pastureland
M1' .
o f s1�'�?,i. c t. r t+•r#'y T.• Line Features
Lines
'I F.Fj, 1R'nw =N7.Y' S�•
, ; r, s�� y,.k; irrigation pull

Operator: Hubbard Baker
Owner: Curti s r K&I�-%,&
Randolph, NC - ENV)
Farm - 3773 Tract(s) - 1433
Conservation Plan Map
Map Use: Nutrient Management
1 inch equals 400 Feet
0 200 400
I� cet
McC2 V / WvB2
McC2
LAWWW
MaC
WPC
fY
S
Prepard wide assistance from:
v N RCS
McB2
WtB
— Roads
C35oiis
— Streams
Field Types
Fields
'[,.,,'� forestland
hayland
tZ headquarters
Ali lagoon
C--3 pastureland
Line Features
Lines
- irrigation pull

Operator: ]Hubbard Baker
Owner: Curtis Ba�trj2trr)Ziu�
Randolph, NC - SWCJ
Farm - 3773 Tract S - 1433
p r. PieWred: 11 /2ED06
4.
1
irfj''� ,j •ti'..' :i pry•
.N-0
` fit¢
yy'�:ryt¢
atd.4 SC
..4
Conservation Plan Map
Map Us.: Nutrient Maragcrnent
i inch equals 400 feet
0 200 400
Feet
NN
T
S
N R C S
.p.. y. y ..,.
b��;. ,� ii x•, y�rr' N_ r5 -�.it y; JV : i.r n. ,¢;�:^� .'I. �, l", t"y f �R ei• V }J 3S'41.Y� i, a.l li.i ,..
T •�}❑!f1Cl��j��°iJr• •4 W•i,�-.e ?,�' R y}•i��-•.• ef'.wr'.i.;2'?'
ti ° LT ,BSI'. 73. N•r ,. 911�-�� }r•'.y� $_�^'•. 'N^-�/
•�, •�',�.5 ; v •�� 'x i� •'�."rwT� •,F"�+;is� " y� 11 ix, y'rr i'H4 .. c'4,:�i•�•�'
! Fay r'. #i`�1.;�i *� �nete� +'ti. `�•
' � �i r. � ^T � ..> ���•, WE
fy;nkes.SJiAr•;1���40
rY!•�Zc
)l•'T' '
���•- R y
Rr
PA•��r;at�3
x ! E.. F f. + p �_ i �.' .' i +�` ".F ..:►!k.►
r OR,
•rii����11 ,P ) a�..•-:.i+ i�j '-� .nG-�a; •r .si+•j• is ,� ! •1i' R,}:
%v^+t• R � %R w,': i��, ai � ,.[ {�.r' :�:..I; .i••:e,.�'+:.7�, a�E.•: "f �� �^ Y YyyrM 91 IS, i
�� . �_+ ,p":;.��".3'' �'F� fi� r�i `r� �d�-4 .r+�.'.'�1 �� h_ • (r,.�..Y`.Yrr}n, � e�^r ��i :Y ,,� fy„
„„��, �7i S 4. r t+. rt s. r.'yy 6 g:�. st • 41YKzRI ./A �.
F•�].'.��q� �- �3 Y �"{M .1+, A►� : X.
�$. ��„� t�!� � `�i .� f,7,�r .� I�' �'� ;i �', `n •t`=+'•,�`��� "�l :�y��`= �,3,rf
[Y +. jyyy! - ¢•a a. ' i�{�3 +� p �i . f•�' {'�.7 ,� yT• r� 9'�... �•i;�• 1(y,Y�:•yA
n•� Z •Q1'. !A �1N 13 .E J • i �. �!�� 'f -R •- =1' _�i �; a/_ i;e e: ; C�, . ` Fir ��•'� ±'
.y "Y•-S, 1 L f' 'l T 1 l ypi'�- Y• F
■. ■ +� ron- }`� ...:. t titer
r��,�};: ���.��.. � rE.�� :�.f;•;� �'.:�3 ,., r�"`1•L e,r� l$.�;..r,���it�� �: :eyr"`'�rf•i � [F
'3,srx.+Fl: .� ,.�� •:� �� ^ � Y:Fti-.': 'a`'"• � �
• r., y .�• At.,( y.i e n. 26' : �.4:::?a
!rr ,�,� •s r =r , Y q f�A} ir. '� ..M .8y�dc •.r r' '. �5■ j+ r.-r ; .,i•
1. � r��f r�?.: ;a• !r r � •'ye fF4�t.•;w� L.'' f F'�' .�, V �•'�" � y ' �� ;.
_.y :.T eao_cc�wo �� A' �� in��1•r..ii.-.-S J+T+-,.1 +� �y� • .. y. *" E..� F' �
•U,"'".. r,i.�( � , r ,,Y �� I oaae0000:`ji�R�; � E "� • �.'�'�+" �,'{ �y,�!A�•ZL �� �.. •
4: •I::wn'-�.., a F• �.r:•_r'• : E' Y7i i• a �° ,�1"j}'+�.<;�k`
U 41y -y•l •n Hse"�..,. r fi ,x: y4+t�'& 1• kL'k'' _
sie •�.
,�,. �. •� J�i;;g� 'F 'Y 'ew ��.*�F ?.��` '� f�. f � ��n �1" •}t, �'i :`•� :l ��s ,}" . � �r�':�y ;,�,: 's,::..+r .� . •�,�=_:��'�F.��"`Y" �•3 �s.,a ■ 1���i
rtr. ,.Lsr K [ xx r . � �A x. +. ':�7.a � l � � '4 �,'•. a k �t i' IY�S. �.j:1�r.�{.e " {
�� L`E •. L E�i•r r'V. '�7. •-'�v. : i �;%} � 7 '. •1SE'-f �� . � �..- � ��•'C '�i .
Cr ,ram ,• U✓?+. r�n;ls vyy�'�';a:....i''�,�ri- J:1?.#,�{ f'sk y� •. r/>t..sw r 1. w/.�, ..! :,�ri':•t4"5.�`,y .,� �°f``:. rY 'r,-i w.l.'i`sv
W q, =V u�.,� aaaae4�ma,d�.a.,n �caaQcd C`"•%�';hW.
,r ery�°:: ■ p4�
v� + IT
.�.,
■ �',' "l_ v N.:'•i #K' r tee'_ tiA
F., +
�,yti_,�.�r11r .�-[!N,. ..a.j tea.. _ryh � �.�iy�� �.��4..y ��} .�ni � ��sy �!.'• ,/?7'�`an,i
L. n.
•^.�rCC r' *i ay + ` •a��ry•'Y� �i,`e'L. � 't� j46;
I p °•�,_►[7C^�ii�+:Y[��lf,•: aH w .! ..+;%d'.r��'59•T�i.-3:y} , w
y, , '+ �.S%ii�=•a.�y.". .r lity"��'•"�...• •ty� �.r..j•k nd •r-� '{�,•3,; • �k ;r'
'-'Y,r • Y •p� ti�r,#sr'CS � �.
=r` L��4 `��y�_ .:ieri,���'" ���• ^`W�"" r. - #�i �,}} L.l "}�� is i• 1� .:• .,.a.>2' rsr��r� . �i��
^may `'� *` I'rw i{'4 �"T •� �7 1' F ��.
•Sr **V; r y. r.[ �f �k Hwy:'
i ��1'�r,yir.' "i.{q�•�'p�«-°'�+a: `t.'�ti=•i.�'{x�A'.a�x�'' �'r�"
t .al z t,.,l � tl�si'T �� ;y-2'•l '� S" ' • �' �•r ` i P' { -- Roads
%n ' "1. v
y F', 14,�,+'k�� a•c;f�*y�.'y;z�.._iyy ._ t�•.�►'r.4.lt [f[� —Streams
"4i� Xf s.iM i, Field Fypes
�• y ,,
yya �••..� !V.'ri R° '',+ �ir��+.,, rrJ,y:+�M1y�1",; \ y��.T.. r.� f �,7 �.�'•'p.;K '�L r'{ .AR.. ` •��a :11,4r5�r.", .;f.`]��I •i}aY•./'•'if,/" {�ir•';•1.w9c�J ^��+F• Fields
.:.r.,lk C�:>r..R'1►ip►y4ifi:�'' i ' ;'7'i�... C3forestland
# r k.., ' . •';,;,��hayland
r;•: �l: �, r C3headquarters
Wlagoon
�1 r '►�I.:;y'-. ,i� l"i �'71, > tw. L'R• * n ,f,':4. !
� b�,�` 4" }� �°����: ���1tir � -Rry h �'. �r-•'+F •�;e, rig ry�
=l. }„ �• + y.:� . �1..■ i Gk. ,� y ..� r.,.. a �T`�:. ■. �.r r •Str+• , :41 i 'Y•� C3 pastureland
�� •yp•S i�� _.ri''r5tii,...]"''1rT'•L�� �.--,':fr .l, ,.,}.,.
7�f• 1 : {,��.� �•.�•,'1 � �" Y�.,4t+,r•- �3 r `�•j^ � r 7ls �Tr
I," "*'r it�is.z`�;�`"y/J;�i_ %• 1 T �4 �s �'' !Yi��+,IL ,7�l�?,i• it+�"?�//r�V���`"IS,i';''•K#
-1E•
Line Features
k Lines
--lfffgatoi3Uilt Z•

Q=a
4
NCDENR
North Carolina Department of Environment and Natural Resources
Beverly Eaves Perdue
Governor
Hubbard D Baker
Baker Farm
3113 Marlboro Church Rd
Sophia, NC 273503113
Dear Hubbard D Baker:
Division of Water Quality
Coleen H. Sullins
Director
October 1, 2009
RECEIVED Dee rreernan
N.C. Dept. of ENR Secretary
OCT 14 2009
Winston-tialvm
Regtana$ Office
Subject: Certificate of Coverage No. AWS760010
Baker Farm
Swine Waste Collection, Treatment,
Storage and Application System
Randolph County
lit accordance with your renewal request, we are hereby forwarding to you this Certificate of Coverage
(COC) issued to Hubbard D Baker, authorizing the operation of the subject animal waste management
system in accordance with General Permit AWG 100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for the Baker Fann, located in Randolph County, with a swine animal capacity of no
greater than the following annual averages:
Wean to Finish: Feeder to Finish: 1900 Boar/Stud:
Wean to Feeder: Farrow to Wean: Gilts:
farrow to Finish: Farrow to feeder: Other:
If this is it Farrow to Wean or Farrow to Feeder operation, there may be one boar for each 15 sows, Where
boars are unnecessary, they may be replaced by an equivalent number of sows. Any of the sows may be
replaced by gilts at a rate of gilts for every 3 sows.
The COC shall be effective from the date of issuance until September 30, 2014, and shall hereby void
Certificate of Coverage Number AWS760010 that was previously issued to this facility. Pursuant to this
COC, you are authorized and required to operate the system in conformity with the conditions and
limitations as specified in the Genera] Pennit. the facility's CAWNIP, and this COC. An adequate system
for collecting and maintaining the required monitoring data and operational information must be
established for this facility. Any increase in waste production greater than the certified design capacity or
increase in number of animals authorized by this COC (as provided above) will require a modification to
the CAWMP and this COC and must be completed prior to actual increase in either wastewater flow or
number of animals.
Please carefully read this COC and the enclosed State General Permit. Please pay careful attention to the
record kce in ,, and monitoring conditions in this permit. Record keeping, fonns are unchanged with this
General Permit. Please continue to use the same record keepinf; forms.
1636 Mail Service Center, Raleign, Nom Carolina 27699.1636
Location. 2728 Capital Blvd , Raleigh, North Carolina 27604
Phone: [phone] FAX; 919-715-05891 Customer Service: 1.877.623.3748
Internet www.ncwaterquahtv.org
01u•
NorthCarolina
An Equal Oppomnily l Affirmaave Acton Ern*yer

It' your Waste Utilization Plan (WUP) has been developed fused ors site -specific infonnation, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WU1' developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws. rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Per 15A NCAC 2T .0105(h) a compliance boundary is provided for the facility and no rsew water supply
wells shall be constructed within the compliance boundary. Per MRCS standards a 100-foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CANNIMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-? 15.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, then an application for renewal must be filed at least 180 days prior to expiration.
'Phis CDC is not automatically transferable. A name/ownership change application must be submitted to
(lie Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Unit for infonnation on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition 1I.22 of the General Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning. Tropical Stone Warning.
or a Flood Watch associated with a tropical systems for the county in which the facility is located. You
may find detailed watchlwaming information for your county by calling the Raleigh. NC National
Weather Service office at [phone], or by visiting their website at: wwA,.erh.noaa.gov/er/rah/
This facility is located in a county covered by our Winston-Salem Regional Office. The Regional Office
Aquifer Protection Staff may be reached at [phone]. If you need additional information
concerning this COC or the General Permit, please contact the Animal Feeding Operations Unit staffat
[phone].
Sincerely.
414 "
fin- Colcen H. Sullins
Enclosure (General Penn it AWG100000)
cc: (Cenificate of Coverage only for all ccs)
Winston-Salem Regional Office, Aquifer Protection Section
Randolph County Health Department
Randolph County Soil and Lester Conservation District
A P S Central Files (Permit No. AWS760010)
AFO Notebooks
N G Purvis Farms Inc

Upon abandonment or depopulation for a period of four years or more, the Permittee. must submit
documentation to the Division demonstrating that all current MRCS standards are met prior to restocking
of the facility.
Per NRCS standards a 100 foot separation s;iall be maintained between water supply wells and any
lagoon or arty wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified. in this CDC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration (late of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A namelownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this CDC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Winston-Salem Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. if you need additional information concerning
this COC or the General Permit. please contact J R Joshi at [phone] ext. 363.
Sincerely.
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG 100000)
cc: (Certificate of Coverage only for all cc's)
Winston-Salem Regional Office, Water Quality Section
Randolph County Health Department
Randolph County Soil and Water Conservation District
Permit File AWS760010
NDPU Files
.•NrN
��CEIV�t]
N.C. EHNS
MAY 1 9 2003
WI n'� Y� -.--::;i=1em
Regional Office
M

OF VJ A TEq Michael F. Easley, Governor
O� QG William G. Ross Jr., Secretary
North Carolina Department o! Environment and Natural Resources
y Alan W. Klimek, P. E., Director
Division of Water Quality
May 1, 2003
Hubbard Baker
Baker Farm
3113 Marlboro Church Road
Sophia NC 27350
Subject: Certificate of Coverage No. AWS760010
Baker Farm
Swine Waste Collection, Treatment,
Storage and Application System
Randolph County
Dear Hubbard Baker:
On April 28, 2003, the North Carolina General Assembly ratified Senate Bill 733 which directs the
Division of Water Quality (Division) to extend the expiration date of the Swine Waste Operation General
Permit AWG100000. Therefore, the General Permit has been re -issued by the Division to extend the
expiration date to October 1. 2004. During the period of this extension the Division will be working with
all interested parties on the development of a new version of the Non -Discharge General Permit.
In accordance with your application received on February 20, 2003 and in accordance with the directive
r of Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to
Hubbard Bakei, authorizing the operation of the subject animal waste collection, treatment, storage and
land application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AWS760010 which expired on April 30, 2003.
This approval shall consist of the operation of this system including, but not limited to. the management
of animal waste from the Baker Farm, located in Randolph County, with an animal capacity of no greater
than an annual average of 1900 Feeder to Finish swine and the application to land as specified in the
facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or Farrow to
Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary, they may
be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a rate of 4
gilts for every 3 sows
The COC shall be effective from the date of issuance until October 1, 2004. Pursuant to this COC. you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this CDC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
NCR
Non -Discharge Permitting Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
Customer Service Center
An Equal Opportunity Action Employer
Intemet httpJ/h2o.enr-state.no.uslndpu
Telephone [phone] Fax [phone]
Telephone [phone]
50% recycled110% post -consumer paper

•
0
Nutrient Management Plan For Animal Waste Utilization
This plan has been prepared for:
Hubbard Baker
Hubbard Baker
3113 Marlboro Church Road
.Sophia, NC 27350
336-498-3973
02-03-2003
This plan has been developed by:
Jerii, Raynor
Randolph SWCD
241 Sunset Ave
Suite 105, Federal Bldg
Asheboro, NC 27203
per 6Si4g9nai7 DeNper
Type of Plan: Nitrogen Only with Manure Only
Owner/Manager/Producer Agreement
i (,tve) understand and agree to the Specifications and the operation and maintenance
procedures established in this nutrient management plan which includes an animal
waste utilization plan for the farm named above. l have read and understand the
Required Specifications concerning animal ►►•aste management that are included IN, ith
this plan.
Signature (owner) Date
Signature (manager or producer) Date
This plan meets the minimum Standards and specifications of the U.S. Department of
Agriculture - Natural Resources Conservation Service or the standard of practices
adopted by the Soil and Water Conservation Commission.
Plan Approved B 01, 3
Tech ' 1 Specialis ignature ' Date
------•------------------------------------------------------------------------------------------------------------------------------- -------------------
540177 Database Version 2.0 Date Printed: 02-03-2003 Cover Page I

•
•
Nutrients applied in accordance with this plan will be supplied from the
following source(s):
Commercial Fertiliver is not included in this plan.
S7
Swine Feeder -Finish Lagoon Liquid waste generated 1,761,300 gals/year
by a 1,900 animal Swine Finishing Lagoon Liquid operation. 'Phis
production facility has waste storage capacities of approximately 180 clays.
Estimated Pounds of Plant Available Nitrogen Generated per Year
Broadcast
4057
Incorporated
6967
Injected
7672
Irrigated
4409
Actual PAN Applied
(Pounds)
Actual Volume Applied
(Gallons)
Volume Surplus/Delicit
(Gallons)
Year 1 --r
4,657.16
1,860,260
-98,960
------ --- ---- --- -- ----- -- -- - -- -- - ---
Note: In source II?, S means standard source. U means user defined snisrce.
4321 G4 Database Version 2.0 Date Printed: 02-03-2003 Source Page I of I

•
•
The t,tbIc slit)wn below provides a summary of' the crops or rotations itic Itulccl in this plan for cacti field.
Realistic Yield estimates are also provided fir each crop in the plan. In addition, the Leachinl; index ror each
field is shown, where available.
Planned Crops Summary
'bract
field
Leaching
]ndc.x [LI1
Soil Series
Cro Sequence
RYE
1470
2 (IB)
VIA
%teeklenburk
fescue flay
4.5 Tons
1470
2 t2131
NIA
%lecklenbuTa
Fescue flay
4.5 Tons
1470
2 0)
NIA
%clecklenburu,
Fescue flay
4.5 Tons
1470
2 0)
NIA
Mecklenburs;
Fescue flay
4.5 Tons
1470
3 ( IA)
N(A
Mecklenburg
Fescue flay
4.5 Tons
1470
3 (2A]
\IA
Mecklenburu
Fescue flay
4.5 Tuns
1470
4(5)
NIA
Badin
Fescue flay
4.0Tons
1470
4(6)
NIA
Radin
Fescue flay
4.0Tons
1470
4(7)
VA
Badin
Fescue Clay
4.0'I'ons
Ll
Potential Leaching
Technical Guidance
Low potential to contribute to
None
2
soluble nutrient leaching below the
root Zon C.
> = 2 &
Mode rat c potential tc contribute to
Nutrie'rtt ~Management (5 90) should be planned.
< = 16
soluble nutrient leaching below the
root none.
14igh ]x)tcntia] to contribute to
Nutrient ,Manage mcnt (590) should be planned. Other con sen•ation practices that improve
soluble nutrient leaching below the
the soils availAe water holding capacity and improve nutrient use efficioicy should be
f]
root vonc.
considered. Examples are Cover Crops (340) to scavenge nutrient~, Sod- Bastd Rota lions
(329), Lon g=Perm No -Till (778), and edge -of -field practices such as filter Strip s(393) and
Riparian forest Buffers (39l).
432164 Ilatabase Version 2.0 Elate Printed: 02-03-2003 PCS Page t of 1
NOTE: Symbol * :Weans user entered data.

The Waste Utilization table shown below summarizes the waste utilization plan for this operation. This plan provides an estimate of the number of acres of
cropland needed to use the nutrients being produced. The plan requires consideration of the realistic yields of the crops to be grown, their nutrient
requirements, and proper timing of applications to maximize nutrient uptake.
This table provides an estimate ofthe amount of nitrogen required by the crop being grown and an estimate of the nit togen amount being supplied by manure
or other by-products, commercial fertilizer and residua] from previous crops. An estimate of the quantity o€-solid and IigLlid waste that will be applied oti each
field in order to supply the indicated quantity of nitrogen from each source is also included. A balance ofthe total manure produced and the total manure
applied is included in the table to ensure that the plan adequately provides for the utilization ofthe manure generated by the operation.
Depending on the requirements of the crap and the nutrient content of the waste, some nutrients xV`1II likely be over or under applied if animal waste is being
utilized. Waste should be analyzed before each application cycle and annual soil tests are required ifanimaI waste is being applied. Soil tests should be used
to balance the nutrient application amounts with the realistic yields of the crop to be grown. Nutrient management plans may require that the application of
animal waste be limited so as to prevent over application ofphosphorous when excessive levels of this nutrient are detected in a field.
Waste Utilization Table
V •ar 1
Tract
Field
Source
I.D.
Soil Series
Total
Acre
Use.
Acres
Crop
RYE
Applic.
Pcriod
Nitrogen
PA
Nutrient
Req'd
I.
Comm.
Fm-
Nutrient
Applied
�.
Rcs.
(Ibs1A)
Applic.
Method
Manure
PA
Nutrient
Applied
Liquid
Manure
Applied
(acre)
Solid
Manure
Applied
(acre)
Liquid
Manure
Applied
(field)
Solid
Manure
Applied
[Field]
N
N
N
IWA
iwo
I Ral1A
tons
1000 cats
tnnS
i470
2 (IB)
S7
tilecklenburg
1.16
1.16
Fescue Hav
4.5 Tons
811-7131
200
0
0
lrrir;.
200
79.89
0
92,67
0.00
1470
2 (213)
S7
Mecklenburg
2.55
2.55
Fescue Hay
4.5 Tons
811-7131
200
0
0
lrrirt.
200
79.89
0
203.72
0.00
1470
201
S7
Mecklenburg
3.12
3.12
Fescue Hay
4.5 Tons
8.11-7131
200
0
0
lrris;.
200
79.89
0
249.25
0.00
1470
201
S7
Mecklenburg
4.48
4.48
Fescue Hav
4.5 Tons
8.11-713)
200
0
❑
brie.
200
79.891
0
357.90
0.00
1470
3 HA)
S7
Mecklenburg
1.16
1.16
Fescue Iiay
4.5 Tons
8.11-713)
200
0
0
Irriu.
200
7%89
0
92.67
0.00
1470
3 t2Al
S7
Mecklenburg
1.37
1.37
Fescue Hay
4.5 Tons
811-7131
200
0
0
lrria.
200
79.89
❑
109.45
0.00
1470
4151
S7
Badin
3.72
3.72
Fescue Hav
4.0 Tons
8.11-7131
173
0
0
Irrie.
173
69.10
0
257.06
0.00
1470
4(611
S7
Badin
3.51
3.511
Fescue Hay
4.0 Tons
811-7131
1731
0
0
brit;.
173
69.10
0
242.55
0.0❑
1470
4171
S7
I Badin
3.69
3.69
Fesc tic I i a v
4.0'1'ons
8/1-7131
173
0
0
brie,
03
69.10
U
254.99
0.00
..................... ........ ....... ..-. .-.. ---------............ ------ -.---
432164 Database Version 2.0 ❑ate Printed. 213103 WUT Pate 1
0-
9

Waste Utilization Table
' ar
Tract
Field
Source
I.D.
Soil Series
Total
Acre
Use-
Acres
Croo
RYF
Avvlic_
Period
Nitrotten
PA
Nutrient
Req'd
Comm.
Fert-
Nutrient
Applied
Res,
OWA)
Applic.
Method
Manure
PA
Nutrient
Applied
Liquid
Manure
Applied
{acre)
Solid
Manure
,applied
(acre)
Liquid
Manure
Applied
(Ficld)
Solid
l4anure
Applied
[Field]
N
ti
N
lbs.+A
1000
cal/A
tons
1000 eals
tons
Total Applied, 1000 gallons
1.860.26
Lagoon Liquids
Total Produced, 1000 gallons
1.761,30
Balance, 1000 gallons
•98-96
Total Applied. tons
0.00
Manure Solids
Total Produced, tons
0.00
Balance, ions
O.oO
Notes: 1, 1n the tract column, svmboI — means leased. others ise. ou ned.
2. SvmboI ' means user eme red data.
............................................ .......... ........... . ....... ------------ .....---------- .---------- ....---------------------- I-- .. ..... I ....... — ----------
432164 Database Version 2.0 Date Printed: 213103 WUT Pace 2
0-
0

The Irrigation AppIicaIWri factors for each field in this plan are shown in the follonring table.
Infiltration rate varies with soils. If applyingwaste nutrients through an 1nigation system, you must
apply at a rate that will not result in runoff. This table provides the maximum application rate per hour
that may he applied to each field selectee] to receive wastewater. It a]so lists the maximum application
amount that each field may receive in any one application event.
Irrigation Application Factors
Tract
Field
Soil Series
Application Rate
(inchcsfhour)
Application AtnoLont
(inches)
1470
2 (1B)
Mecklenburg
0.30
1.00
1470
2 (2B)
Mecklenburg
0.30
1.00
1470
2 (3)
titecklcnburg
0.30
1.00
1470
2 (4)
Mecklenburg
0.30
1.00
1470
3 (]A)
Mecklenburg
0.30
1.00
1470
3 (2A)
Mecklenburg
0.30
1.00
1470
4(5)
Badin
0.30
1.00
1470
4(6)
Badin
0.30
l AU
1470
4(7)
Badin
0.30
i.00
432164 Database Version 2.0 Date Printed: 02-03-2003 tAF Page i of 1

•
•
The following Lagoon Sludge Nitrogen MiIization table provides an estimate of the numberof acres needed for
sludge utilization for the indicated accumulatioit period. These estimates are rased on average nitrogen
concentrations forcacIt source, the nuntberofanimaIs in the facility and the plant available nitrogen application
rates shown in the second column.
Lagoo it sludge contaiits nutrients and organic inatter remaining after treatment and application of the cffluelit. At
clean out, this material must be utilized for crop production and applied at agronomic rates. In most cases, the
priority nutrient is nitrogen but other nutrients including phosphorous, copperand zinc can also be limiting. Since
nutrient levels are generally eery high, applicat1011 of sludge must be carefully applied.
Sites must first be evaluated for their suitability for sludge application, Ideally, effluent spray fields should not be
used for sludge application. If this is not possible, care should be taken not to load effluent application fields with
high amounts of copperand zinc so that additional effluent cannot be applied. On sites vulnerable to sit rf'ace water
moving to streams and lakes, phosphorous is a concern. Soils containing very high phosphorous levels may also
be a concern.
Lagoon Sludge Nitrogcn Utilization Table
Crop
Maximum
PA-N Rate
lblac
Maximum Sludge
Application Rate
1000 gallac
Minimum Acres
5 Years Accumulation
Minimum Acres
10 Years Accumulation
Minimum Acres
15 Years Accumulation
Swine Feeder -Finish Lagoon Sludge - Standard
Cum 120 bu
150
13.16
23.82
47.64
71.46
flay 6 ton R.Y.E..
300
26.32
11.91
23.82
35.73
Soybean 40 hu
160
14.04
22.33
44.6E
66.99
--------------•-•----.................. ......... ------ ---•--• ------- -----
432164 Database Version 2.0 Date Printed: 02-03-2003 Sludge Page 1 of t

The Available Waste Storage Capacity table provides an estimate of the number of days of' storage
capacity available at the end of each month ofthe plan. Available storage capacity is calculated as the
design storage capacity in days minus the number of days of sic storage volume accumulated. The start
date is a value etile red by the user and is defined as the date prior to applying nutrients to the first crop 111
the plan at which storage volume in the lagoon or holding pond is equal to zero.
Available storage capacity should be greater than or equal to zero and less than or equal to the design
storage capacity of the facility. If the available storage capacity is greater than the design storage
capacity, this indicates that the plan calls for the application of nutrients that have not yet accumulated.
If available storage capacity is negative, the estimated volume of accumulated waste exceeds the design
storage volume of the stricture. Either of these situations indicates that the planned application interval
in the waste uti lization plan is inconsistent with the structure's temporary storage capacity.
Available Waste Storaize Canacitv
Source game
Swine Feeder -Finish Lagoon I i uid
Design Storage Capacity (Days)
Start Date
12131
180
Plan Year
Month
Available Storage Capacity (Bays)
1
1
149
1
2
180
t
3
180
l
4
150
1
5
119
t
G
89
1
7
58
1
8
123
1
9
ISO
1
10
149
1
11
119
1
i 12
88
* Available Storage Capacity is calculated as of the end of each month.
4321 C4 Database Version 2.0 Date Printed: 02-03-2003 Capacity Page 1 of I

Required Specifications For Animal Waste ManaLement
1. Animal waste shall not reach surface waters of the state by runoff', drift,
manmade conveyances, direct application, or direct discharge during
operation or land application. Any discharge of waste that reaches surface
water is prohibited.
2. There must be documentation in the design folder that the producer
either owns or has an agreement for use of adequate land on which to
proper]), apply the waste. If the producer does not own adequate land to
properly dispose of the waste, he/she shall provide evidence of an
agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the
responsibility of the owner of the waste production facility to secure an
update of the Nutrient Management Plan when there is a change in the
operation, increase in the number of animals, method of application,
receiving crop type, or available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs
for realistic crop yields based upon soil type, available moisture, historical
data, climatic conditions, and level of management, unless there are
regulations that restrict the rate of applications for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre
per year. Waste may be applied to land eroding at more than 5 tons per
acre per year but less than 10 tons per acre per year provided grass filter
strips are installed where runoff leaves the field (see USDA, NRCS Field
Office Technical Guide Standard 393 - Filter Strips).
5. Odors can be reduced by injecting the waste or by disking after waste
application. Waste should not be applied when there is danger of drift
from the land application field.
6. When animal waste is to be applied on acres subject to flooding, waste
will be soil incorporated on conventionally tilled cropland. When waste is
applied to conservation tilled -crops or grassland, the waste may be
broadcast provided the application does not occur during a season prone
to flooding (see "Weather and Climate in north Carolina" for guidance).
---------------------------------------------------------------------------------------- ---
432164 Database Version 2.0 I7ate Printed; 2/3103 Specification Pne 1

7. Liquid waste shall be applied at rates not to exceed the soil infiltration
rate such that runoff does not occu r offsite or to surface waters and in a
method which does not cause drift from the site during application. No
ponding should occur in order to control odor and [lies.
8. Animal waste shall not be applied to saturated soils, during rainfall
events, or when the soil surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner
that the crop is not covered with waste to a depth that would inhibit
growth. The potential for salt damage from animal waste should also be
considered.
10. Nutrients from waste shall not be applied in fall or winter for spring
planted crops on soils with a high potential for leaching. Waste/nutrient
loading rates on these soils should be held to a minimum and a suitable
winter cover crop planted to take up released nutrients. Waste shall not
be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with
the following: The outer perimeter of the land area onto which waste is
applied from a lagoon that is a component of a swine farm shall be at least
50 feet from any residential property boundary and canal. Animal waste,
other than swine waste from facilities sited on or after October 1, 1995,
shall not be applied closer that 25 feet to perennial waters.
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other
than those owned by the iandowner.
14. Waste shall be applied in a manner not to reach other property and
public right-of-ways.
----------------------------------------------------------------------------------------------- ----------------------------------.................
432164 Database Version 2.0 Date Printed: 213103 Specification Page 2

15. Animal waste shall not be discharged into surface waters, drainageways,
or wetlands by a discharge or by over -spraying. Animal waste may be
applied to prior converted cropland provided the fields have been
approved as a land application site by a "technical specialist". Animal
waste shall not be applied on grassed waterways that discharge directly
into water courses, and on other grassed waterways, waste shall be
applied at agronomic rates in a manner that causes no runoff or drift
from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets,
sinks, etc., shall not be discharged into the animal waste management
system.
I7. A protective cover of appropriate vegetation will be established on all
disturbed areas (lagoon embankments, berms, pipe runs, etc.). Areas
shall be fenced, as necessary, to protect the vegetation. Vegetation such as
trees, shrubs, and other woody species, etc., are limited to areas where
considered appropriate. Lagoon areas should be kept mowed and
accessible. Berms and structures should be inspected regularly for
evidence of erosion, leakage, or discharge.
18. If animal production at the facility is to be suspended or terminated, the
owner is responsible for obtaining and implementing a "closure plan"
which will eliminate the possibility of an illegal discharge, pollution, and
erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected
on a regular basis to prevent breakdowns, leaks, and spills. A regular
maintenance checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other
crops for direct human consumption. However, if animal waste is used on
crops for direct human consumption, it should only be applied pre -plant
with no further applications of animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and bottom
elevations of the temporary storage (pumping volume) of all waste
treatment lagoons. Pumping shall be managed to maintain the liquid level
between the markers. A marker will be required to mark the maximum
storage volume for waste storage ponds.
- ---- ----- ---
4321C4 Database Version 2.0 I]ate Printed: 213l03 Specification Pau 3

22. Waste shall be tested within 60 days of utilization and soil shall be tested
at least annually at crop sites where waste products are applied. Nitrogen
shall be the rate -determining nutrient, unless other restrictions require
waste to be applied based on other nutrients, resulting in a lower
application rate than a nitrogen based rate. Zinc and copper levels in the
soils shall be monitored and alternative crop sites shall be used when
these metals approach excessive levels. pH shall be adjusted and
maintained for optimum crop production. Soil and waste analysis
records shall be kept for a minimum of tine years. Poultry dry waste
application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for tine
(5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina
regulations.
--- ---- ------ ----------------------------------------------------------------------- ------ ----
432164 Database Version 2.0 ])are Printed: 213103 Specification 1'asze 4

Crop Votes
The following crop note applies to fieid(s): 2 (1 B), 2 (2B), 2 (3), 2 (4), 3 (1 A), 3 (2A)
Fescue: Piedmont
Adaptation: Well -adapted.
In the Piedmont, tall fescue can be planted Aug. 20 to Oct. 10 (best) and Feb. 15 to Mar. 20. For
pure -stand broadcast seedings use 20 to 30 lblac., for drilled use 15 to 20 lblac. seed. Use certified seed
to avoid introducing weeds or annual ryegrass. Plant seed 0.25" to 0.5" deep for pure stands, 0.25" in
mixture with clovers. Sol] test for preplant and maintenance lime, phosphorus, and potassium
recommendations. Apply 40 to 60 lblac nitrogen at planting for pure stands only. Do not apply N for
mixtures with clovers but use proper legume iroculation techniques. Apply 150 to 200 ]blac. N to
pure -stand fescue for hay production; reduce N rates by 25` , to 50% for grazing. Apply N Feb. l to Mar.
20 and Aug. 20 to Sept. 30, with equal amounts in each window. Refer to NCSIJ Technical Bulletin 305
Production and Utilization of Pastures and Forages in North Carolina for additional information or
consult your regional agronomist or extension agent for assistance.
The following crop note applies to field(s): 4(5), 4(6), 4(7)
Fescue: Piedmont
Adaptation: Well -adapted.
In the Piedmont, tall fescue can be planted Aug. 20 to Oct. 10 (best) and Feb. 15 to Mar. 20. For
pure -stand broadcast seedings use 20 to 30 ]blac., for drilled use 15 to 20 ]blac. seed. Use certified seed
to avoid introducing weeds or annual ryegrass. Plant seed 0.25" to 0.5" deep for pure stands, 0.25" in
mixture with clovers. Soil test for preplant and maintenance lime, phosphorus, and potassium
recommendations. Apply 40 to 60 lblac nitrogen at planting for pure stands only. Do not apply N for
mixtures with clovers but use proper legume inoculation techniques. Apply 150 to 200 lblac. N to
pure -stand fescue for hay production; reduce N rates by 25% to 50% for grazing. Apply N Feb. 1 to Mar.
20 and Aug. 20 to Sept. 30, with equal amounts in each window. Refer to NCSU Technical Bulletin 305
Production and Utilization of Pastures and Forages in North Carolina for additional information or
consult your regional agronomist or extension agent for assistance.
... ....... .......... ......... ......... .._.... ............................................................
432164 Database Version 2.0 Date Printed: 02-03-2003 Crop Note Page p of i

�F�kv
4 r• 1 v i .1,,r4 G C .� . i +y e'L'f
y, `` •,MKS: r o f I j + [ . } ..:.� & .-t a^".f i �tib'
? �"} { 4
_lye j3ty��,.
,J -!�, ..{f �7•' y `� s '5•�:-� • • _ _ 11�� q r�• h � �}F-•.,�• "'� y ^� . r .-{,I�" �. - •i 'i���':
e. '� l�� S •-'•S +►a.'r � _ ate` ia' .a ;t:, .�. F'r.� � '"/���jr�L x'• �r�...,.�' ••� >'�]�. '•At* + _
77.
y.� �t:• _ y r Fr�•,_jr+Y '/�•' �' ,,": , �r w .....aaaaaaaaa��� _ ,'_
_ }�i•c/-L�r� ,{•+; Ya 7^�kf�ii�l f���y � � t -f�•r �r•�•}��_�3•�1'�� �?:•_• i� �.•J1 - �.LA' }f � ��• ,4 i'�r�fJ, 1 • •,��1f .
�. rr� - •r�:.- .=i L. L, '� f ��^ N: •y.>�' : 7 �� ' � ty�'� _► �,,y�� � '�'�. f e • �� • r t.
�' � .f}r:�•-,5y,<. 1 • • � � S ,. � ! r - � i'.'� '� i ti'r art ...•�•�1 �` i� • � ilyZ''='r:' r,.• _ �r:i`=.w ' � stY t * +
Y }isi• u;.� � '% •. R .a• � '•�?_,..�a• �•�u ti,'�.x.• :�.•r''tr •� L, r5.7 •^*�4• � • §lam a.���t1:',�i�� t�' ti � ` ;•�c.�
i + � ��% 1!• 1Rt F• ,,. 1 �. r_ r .-.ra�;�r. ,.�� .. ,._. � r � } *C. r � � s,', : - "• { • -
��rr ,'y. r It 11"` L I rJVpi� "+ j, •' K •I r ,w f.:!�i �- ,y
,`'' �,I.r-�i•N. ;"_ C.:1 �, `,I L_" .--•r r �. Q�� ,�, t�ryl••. �j�• ylr
si.�r >:,`'d r' r Il•• j„' ��;ilk 1, ✓ y.�'�a�1�F:r'f:=�� „i -1 F �'y ` ..-� _ :�r'r7l�, _fT^+ J[
.�rar' :; .� 1 }• 'f,... ::�.. ;pacer' �]� � °,'f�r-. - 'S.'i , ,.7� L' ,'�h+ � .r `Jxj74
,�[ _
r�. Y4a - r, j� '...� ... �i ;,�.} lr �r �7. �'-!� ':�y. ��i,s'�z:� . ', r- -' r.'i.�.r •~ � , Y E .w+a �. 1�.'T^.:,�'rr•'"'' . :Ii: ��
01
Ld
kTv
v i .• -}'x'4 J [ xi. �• �r •.'a �yt1� `• - � r/� _, i t(.i".}'r�,.',s
_ ��:� :i 3:•-���i.' 'i• {���i4 - , 7!*�y�-r' F1-,7�C+> '•r4� �+' -.ir; - 4•'- 11 + •�'.. =r r jj
' - '•�,I '� ` :� r. ;� . _. r• 1e'�Y.'. 'F, 1, �-:». r .�iiY •1:3' F �.
� ' fir' ._ • • � ' - +(•• �1- rri. - ■ ;�-..- 4
•�� ':. .: '�� v '.L r 'r�T^•�� 4 !^_ = . �••i+y , � :li S=t .SMTsie� � . -�.
;.� .`-i,jy, .1• �i• L- ..eS-,;l:^'.:�rf 3Y �l.yr 'J'+'Yi' r•' 'M: li.-v_,� r^} -
•f � -•_t.< . .r '-=����{Ci'-::!�!'-:�/: �'{ir`� i• '.�R'':.;'� •+'�i•_:Y: 'ii 's}c••"'T'._ . •.
�_a? ' irk
a� wr}'? c "s'�Yx. � � �'�.�• r�- • •* �j�tiV'ri.ar:i!' 13r,:�;!3��'.• �� a � :'�' � •��
cr
.�. r•' ':r4' 1. r7$r +••L� iH��li',•���`- '�,' '� J. "- � r.� + r�
' l.�.. 1�i'A �'� H�li�1 R'j},✓'• ! ..�T iMIL:�""-`; • R � � 4 "•:1� �. - .� �' y n"'i t � .. �r.. ��:=!. � T 1

E
•
RAN DOLPII COUNTY S 0 1 L AND WATER CONSERVATION DISTRICT
OPERATION AND MAINTENANCE PLAN
PROJEC / ARM: Hubbard Baker
DATA.: November,1998
■ A 4" x 4" treated post, painted white or a 4" diameter schedule 40 PVC pipe with cap,
or any other method of permanently making the designated height shall be placed at
the maximum liquid level at elevation 96.7. At no time should the effluent level rise
above the maximum liquid level, which is 1.8 feet Ievel below the settled top of darn.
■ A visual inspection of the waste storage pond will be performed at least twice a year.
The inspector should check the condition of the dam and the emergency spillway.
The inspector will need to look for signs of slope failure and seepage on the rack
slope and at the (oc of the dam. Also, a very close look will need to be made to check
for signs of damage due to varmint (ground hogs, muskrats, etc.) burrows. A visual
inspection should also be made after heavy rainfall events to ensure that the structure
is not experiencing erosion rills or gullies. Any problems found should be brought to
the attention of the technical specialist for repair recommendations.
• The waste storage pond will need to be mowed twice a year. All eroded areas shall be
repaired and stabilized. Areas that do not have an adequate ground cover shall be
reseeded to provide vegetative cover sufficient restrain erosion. The dam and all
constructed slopes will need to be fcrtilined annually with 500 pounds of 10-10-10 per
acre or its equivalent.
• Maintain all waste handling equipment —pumping, loading, hauling, spreading, etc. —
in accordance with the manufacturers specifications.
All waste application shall be completed in accordance with (lie waste utilization
plan. The waste storage pond will be emptied at the end of each design storage period
CI80 days or 6 months) or as needed due to excess rainfall.
See the attached AFC Agricultural Extension Service Agri -Waste Management
Publication by I7r. ,]amen C. Barker for information on sampling and testing of the
effluent.

G
Hubbard Baker
Mortality -Management Methods
(check- which methods} are being implemented)
$uria€ three feet beneath the surface of the ground within 24 hours after
knowledve of the death. The burial must be at least 300 feet from any flowing
stream or public body of water. r
Rendering at a rendering plant licensed under G.S. 106-169. i
u Complete incineration
J In the case of dead poultry only, placing in a disposal pit of a size and design
approved by the Department of Agriculture
1 Any method which in the professional opinion of the State Veterinarian would
make possible the salvage of pan of a dead animal's value without endangering
human or animal health. (Written approval of the State Veterinarian must be
attached)
❑eeembei- IS. 1996

Hubbard Baker
1
Insect Control Checklist for Animal Operations
Source
Crtusc
136,11's to Control 1115CCIS Siic 5pCC1fic l'rneticcs
�_. -.
_ ..
._ Lirluld Systems ...._ ._ _. ._ ._. _ - .
Mush Clutters
AccumulnHoo of solids
Flush system is designed and operMed
5tiMcicntly to remove nccumulnied solids rrom -
gultcrs as designed.
Remove bridging of accumulatcd sol ids at
•
disclulrgc '
Lngoolls ;llld fits
• UusICrl SuIids
mzllllt;liil Iaguons, Sctlling basins nlld IIIIS IYllerc
pest breeding is apparent 10 minimize the
dusting of solids lu n depth of no more (Imn G -
3 incltcs over more IImu 34"fs of stll race.
I:xCCSSIYc Vegc[ntive
-
Dec;l)•illg vcgnition
- Ti
Mninlnia vegc(ativc control nloug banks of
Growth
lagoons and other impomldments 10 prevent
accllnMIntion ordecaying vegetntive matter
along %Y,RICl'S edge Oli impoundolcnt's perimcrcr.
1)ry Sys[ ell is
feeders FUCLI Spilinge 0 Design, opernte alld rnairltain fccd Syslcols
bunkers and (rotlghs) to minimize the
nccllnwhitim of decaying wnstage•
❑ Clean lip spiIInge oa n routine basis [c.g,, 7 - 1 U-
dny illterwil during summer; 1 S-30 day interval •
during wlrlter).
Feed Stoinge ACclIIltula[iUlls U1 lCcd Icslducs ❑ Reduce muis[llre ilccumuhtlon wltltill mid
around irill cc] We perimeter or reed storage
nrcas by insuring drainage away from site
mid/or providing ndequate C011tailll[lcllt (e.g.,
covered bill for bteNver's grails mid similar high
illoisturc grain products),
❑ inspect for and rcinovc or break up accumulated
solids in filter strips around feed storage as
needcfl.
AN'11C - November 11, 1996, t ;lge I ,

Hubbard Baker
w
.Som-CC
Ciltrse
B5,111s 10 Co11t1-01 Insects 5itc SilCCific PnIctices
AIIi111nI IIoIdlllb AI ens
• ACetlltllllililons ofFlllllillil w-isles
❑
Eliminate low arCils 11int (I' p I[Iolsttire alollg
-Ind fccd wnsiilge
rCllces Slld o111Cr locill[[}Ils 4Y11CCe tYnslC
ilcct1midaics and distL11bmice by in1I11nds Is
rll lnlll1i11.
❑
MiIntain reltce vows mid fII(erstrips nlotirid
F31111i1Z1 1101dillg 71-C,aS i0 111I11i11117C
nccimiLif iitlolls or m-tslcs (I.e., inspect for and
Ieniove or bi'cnk op nccimitllaicd soIids ,is
Dt'y il• mIIIIC 1 fnil11111?g
• AcctlliIithI[tolis of 71111111ii1 misIcs
❑
Reiiiovc 511IIInge oil it mtltilIC bnsis (C.g,, 7 - I F
Systems
,1
[lay 1iim-Yaf (ItIi ilig stinimm'; 15-30 [lay irltct-vnf
(Imil1& 1Y1111Cr) MICIC Illnillll'C Is londcd fu1' frllld
r111plicatioll of L1isimsill.
❑
3'roviLle for nde(luale thninage nt-oinid IInImm
stuckililes.
Cl
his1=1 for slid remove or bleak t111 7cctrilmhoted
wastes hi fifier strips nround stockpiles rind
rmmme Ilandlirrg nt-eas as ncedcd.
Fool, lnarc 111ro n.ilion r-ollisci 111C Coopci-itiive fixtclision Scrvicc, DelmilmeW of f iitumology, 13ax 7613, Notlh Cmrofinrt Susie University,
RnIcigh, NC, 27695-7613.
.,, 0
I I.
•
ANI f C - Nuvc[n bcr 11, 1996, Ping 2

ILI
0-,i'(
die:-+•. -`r'�" � • ^ ��-••�: `y '' r..��! i� :�}.,.4 p.+{,-y.^ytr�. ��'��S;r�R,i'�
��1 "�y�-'�`A:c�' lT4r• i.;�Rt'.. ?•;L4•. iy '.tCw
it.
•: r. f T�.'•''' f y#•w'hi•��•`i r 3
_yalswr`r3.,:t�s:,+'4''Xi�q-vJ•7rhi^:yr�y�''Sa7,�
` h - w 31•* };i a•9'= rsVe �•~uF. r n,f,rr Zk
s f ��,i r� %tr= ' i 7.�' 1' - r: :rr =•r •i ri Y `i q:f. �!�•1i.1'i!" �r!� •~, '� sha
� 1- M�'•y •i 7i.'a' �� R
.�` ,,y .1:4 r* :� ar�f rY �f ,'i" .,)• Et%rC� �ia.s f. .at.:3
:r r .: � i��h'r'y �j� f•�� }•�� j•ti 1 r 4• �•.''1 1" r. i �'i. .� +• r r+ r +�:f �- 4,r.`. .`.""T7,'•<
!: 7rr' lr' Au ;_�••}� .. 1^� F [• (?,•rr�±.• _ �S't.s ?r,. err 1.
fI' ,� � ¢ � r rt%'.: ar.�,} �T:•�yr F+�: �• .1 ,�-., •• _• r,�l= . ` - i+.�•r: �.�E-t # 7 ui!^... ; , y' 1
'.!{ i , "� a �P�.,. 7.L.n., �r •��: v a •r., #. ri•rl "7. ��j tr• ris,
1.
jr/s:!„ T ;."a`:•aI►�7M�.�� •. •S :w.. . ■: 'i' ] r r. �>L ,�.. ;J►, �. i'�y�R` .- F�R
-.r p�.-_i}P_"r
js-r�- fY• ...f.':. ter,=^ ,ir�r.. ice^ ..r�:=
.C,�•� i'r • • s F a•z e' .i,. ♦'r.Y.
�;" Y ,'-ter.• +ire +�,['�'-'•�J•
., i/► =A Y"LT'r �1•'k:. ; r•'w�r2 iiV,��
��,'2�y�Y, 1+�"�'i.� r.L'.' J ::'IR�Y.Sl tiy. t;. 1•
�.q r!�+ -R �'�'sF7•iivr7r•;a r.. ,x_- .�.. I" y:rr"• hi •,el�.L
� ` �{+,r • ��i�!�.�,+�{�.��;�ii : �';+, = i'�.. v_ rc..- r ti..a.r: ;�`-.xrb iJ..�.tr . ', Y.- .. •. .ri.��,. �i ��j7��.'��,'Lw��y ; is5
_ q• ,�. fy7. 7 �}• •:::r•::, . • rr +wa,.w;r.c �•' • • i `�5.�'di'r,'r�'' ?�.s. � r� ■'}rY ',{ .: uti J'7 �fr+. ,}tits• r•-.y3� s
i�[�F'.�+y:i� 1: �� {'y}•4i.} rr -, ,Sn• ' rx:: k4y:•�hMa r•}: r' j•�.,?: sS r��, •w�.�+a,��J'iZ •r .y •"•�rj 3CtZ'•p.r
,; Ea 4 y.•+3 [h �` �'"'!. ► r; ; "•' ''t,. �Y'; k + ;.7j%►��r':1i'+.t.
rS` �. a 1 ra r • {
'# 4- ,..y�. � lu + u+� � $r•s•�+ sr+•zL 4i�•7•' {'•.:., Sy erf'a+r7e •.l?►r�r-.•?{r_7f F•l+%•••s i�.: •C:'i *- %: i
' •1'•+i7i-fir r ..Ji. a�� }. � •i �_ ,rir� r J,> '{ ': F .7 y.. 'A'•'�'ii '.: %7'. i r' i
i �1�s•. `,7r',. f r• 1=•. ' '1.J r r �•dr'a.•N •'�ti,A•r:. r i � , N
•tits u .rk . c. '•" � ►ai ti,',i' •�Z '3 f.•. a ..•:r•" r•? i i;'Y+ •.. !�r
�����}y����`!` ...sits' �'• r - {,•S:.�''• •��. �x8=+•r•r�•i.-^�i. �. S'.� rr^'('..rjf',••�,.r�w•��;}r ':r.l
i#►-"" ay� y.. L;�•f• i •: .+Y�} r. f+a •)..r ,a �„'�! ..:i. , • 'yw�*zti:
x�". �' ��*4••ry•�! +'•S�i 4 �...f t R�'p'�-irr�' �,' �}air Yr�. 711n ��r•i},••. i SF•• f/�' i. r�':*.6H .'�l. f'
1 S :Tr.4� ✓; �r ! C' ! �► W�iS.. �nf7t b'•Rr.] �',�+1Y'•s' Y rrr.,�2;yv,
c. s 'x'1t' �'°�. r' �- ti .7! [rt/r'titi `+1y •i.`,ii �w"'r�`I�'",,.�y"}r�'-S':tjn J� I � T• kr'�+ •I+• ant !F''t�'�:7
•%`•.Si-'; '.�• Sy`* �•.:a !.d,` ,14 i��+'r• . ;} ;1'r�''' �,;,t�iti,"•_"•T��C, ��.:3 'r,�;'re �.:.;,;ep.. r,.. ''•��:ft
�•.`•• F� .�i i !� ''ir-•,,'�• e•;y-• r'f�•443 ��e � s �''t:� a' i- r f #r• � '�:•:
�: P P �'7Ti', T'f, w •n.,y:. :a:a "".�'r ka rF,►. �.i� i .rim y Y'-5 ' rr r. • ?�±5 ,�.:. _ R #•..
7 z .i .s� y' r s!- r'I i �. • yi .• a C i`LY'� rS�C
l ��' �1 • . "•r f} 4- �. �•(.a"' �1'-w•'P;• •.t�;.:fr-: �'S"w� i tiyw.•� +1l.�r'i a s7' �• �a.F••"'ri�•��A:•'•�
�tii! •S; f i�:ii •• Ki.r. 4 �•'' yi�_. �7•. �' � !R. .yr •- Pam•
�.� ''�_. _ ef? t `•• XTi y ' 4 �t•r.•�� _. '�r�,.k. ref his; lial_,, J! ��s•.•- ...•.�
�r• G �'[ _ � r.6 j�t• .!; a r•'ti'- � .t. k•r r'• �}ri� � -.!Y •�a d '' .l.:.f `a.. •�, ram'• � -'•
.r �i: sr�-ra• .n�".7k: 'rJ.3•:i`�ir, { f lir�::ri;: :,n. rr rr 1•' ;'?ram F++:r.
• -� • �4,.t�M�fi^i,+r S. •y'n���•Q�Fj ��..i���/�•� �..�� �"�A�:a:�..L�•. r.'+r. �"C�"���� i �•.r d��/�
Si �y �nM a� it e�Iy �i �• +•a X:ir•`� -�.f .yam ��Z�� •4'7,� i1ti
'��•' • �� i• J � - i4� 'i.-Arm l l5. y-t' y..
y� ��=• - er �r i_T?
`�j;�,' • .i !rry • •.Kjr� $~ ' a^' • �r +r+'J_`CK_ y1 +.r. y ' •; `'�iyh'
irr r Y-- T i •.• •• �'-•• + p}►{ •i r. r. 'r �Clih-•N..}.r•, r.r
*Z Fr'S r _ • ^ �•. j _f7� �ytyTrifSti' J +,..y H•• �. r+M A►: �`. Y`
'� F'd��+�"`Y{' ��4 •rL .�L':: 57�.:,:::i f,i:�.,: �1 �S��a�� '�� ' ;1 '��� ':i. �__7.���`. !•{siry����.eF{r•
_ t. • rit: ."r_ •�' �•'' •- �• ., s a �' " _ u �. { i'...5 ! r.. t. t7.+ {:i-s....Sy '•i
}'p 1•r�. r•'�,• S : � ?Ir'. � . }`{�' ' MS. � H:J'i r i�.�r: •l�• �-. 7���
J" l Je�' ra.►.;•�rr:-.-•�•dy,•' = •�.,.,��t1'�^�''-` fP'r..rir' t�> � -� r i� �yy::ic�7. yx� •rV
. �ar �.' �+S" • �14.'i:� r r: ;1M�5 »1.it �w`:ri .. .. IM.S .r h6'�w }.,f.�. Z�:=„f ;., • �F'"�7 .jA: rr:l:.! w.y ry ..
rr►y `,.V 41 TFr ,i�:J 7:.�, c- ��`;'���t.��y eMhi 4. �F.1,,,,;� .�,i.lic,r � . .. r.z.�,n .l°M�.-R11 .�Tr `^'r,'�••;i �r�. .7.�11 ��:
+tiir��.Cr, '{� •i -+iq$, �yy"v•,: •ri a .N; os
r-1r.. •,.� ��, 41. ROI.i;'••.� •]�•''J, l':.i �' 7• %'• i'.: 4: f� :; �ra.: �..•a
. ,j►+.A C.!�„'i ti!i•�.•yi•u_'�± �, - ..4,�,•rZ,•n. +'�..'•._:�!' 'r:'- ! %:
�
A� ••�-�� F�ti!r J�M.+;{ •�r f�1 •ry� ..4 �-• Yr.,y!:
�� r as rr'�+ r :i L-r•'i�r���.a+':-i' Y'�J':i`'Y• .'r ' :Y*•' !� ; S.ew ':a:%�i- +r' �,,y4 7"r':ll
- r .fi S'.7'.1 f,+tom �. � .. :.. 'G+:{���r?'� •�'w♦: t.'• !. eta•-�;;~ 'Y••
•..+ `"^Y + ` •ipr: S� "'� •hr . � +�.Fi'jT�' �" `' w.�:� ��r-r��f:t ;s, wm -�,�T,
rA ` i .% �,.I•z �'+. i�+i'• f� r f fr.,ti,� • hiSy+l:�.4�r'•d�.•�'r t3 - TyY�i:}���-1� �• • sw'}�
�j,�i-Y�. r �;,�'••1 ;1,15'�:'�t',�-!��� F t t-"•`: �� � T±Vy�"5!.S �::-°ty' � e�� -,y^s y��r•-� _
t xr •' �i'r J r".NT� f-. iCti. Ire• i rt'S'...}_ 5�::.. . •Y• ;�: l:ti�,3•,.�:sP I,s•;��"ww
t•?: , i'�+ ?•:.r_r#' S�'•W>'• 'r.r•'C'-^a' vi L ! k sa;' w . �,Z:i.
:.ai.. ffy ,r. } � �). i^�i.,. �i' ��•.+�. r,-1 V..�.i+4[,� �'�4r {`�!.. ��Y 1.. /''•w .1
� '�i.- „ti' �]'.- 1. �+' _Y1'.:� Y,'. 4yS"- ■.�^�+
_ .' ,. /i y T - ";�J! r�1+'+r��. ! �:-ay.y„J:.+: �..Y .: ;•,�x:-•,: �i i ix -=•-.rv�;+us �r; k.`!•_�+s :�.s.
` 7 x+: �, k J r sI'rf '.r'• 1'�i �. ar.F,�...,'s�.• y
����. - Y• y��a•� -f :l-•.y �-ti �.rr i:�,�li:�� �'-�.�...•�:T'��".;SR;�.�:-:�,±�,tf.5s •!�i,+
+1 ->:, �:i � ".7`'- .! "�.r 1ir, ^► i:` :j `+t4• "'Y�ssy �t.� •. �, �`+"'^';�',.:
na•��{ 3r� � 1• _ -s:..r I � sr 's ��e�z'�.�'rl+� st. �' L:SeP"'{� ��f:•�-: y-r.+ •
t.r�. :3 ..,a.,l. .+r.Jjr!•. - is �_-.. n•Y•y "� *�_ '..,_�," •�- R• �, hl

State of North Carolirl
Department of En\iror9ment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., GovernQr
Bill Holman, Secretary
Kerr T. Stevens, Director
HUBBARD BAKER, JR.
BAKER FARM
3113 MARLBORO CHURCH ROAD
SOPHIA TIC 27350
Dear Hubbard Baker, Jr.:
5
NCDENR
ENVIRONMENT AND NATURAL RESOURCES
February 25, 2000 RECEIVED
M.C. Dept. at EHNR
MAR 0 2 2000
Winston-Salem
Regional office
Subject: Certificate of Coverage No. AWS760010
Baker Farm
Swine Waste Collection, Treatment,
Storage and Application System
Randolph County
In accordance with your application received on August 17, 1999, we are forwarding this Certificate of
Coverage (COC) issued to Hubbard Baker, authorizing the operation of the subject animal waste
collection, treatment, storage and land application system in accordance with General Permit
AWG 100000. This approval shall consist of the operation of this system including, but not limited to,
the management of animal waste from the Baker Farm, located in Randolph County, with an animal
capacity of no greater than 1900 Feeder to Finish and the application to land as specified in the Certified
Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this CDC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this CDC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This request
shall be made within 30 days of notification by the Division.
1517 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled! 10% post -consumer paper

Certificate of Coverage A#60010L ' :•
Baker Faun
Page 2
This CDC is not autoniaticaliy transferable. A namelownership change application must be submitted to
the DWQ prior to a name change or change in ownership.
If any parts. requirements. or limitations contained in this CDC are unaccep[Lblc. you have the right to
apply for an individual non -discharge permit by contacting the engineer listed below for information on
this process.. Unless such a'request is made within 30 days, this COC shall be final and binding.
The subject faint is'lkated• in the Winston-Salem Regional Office. The Regional Office Water Quality
Staff may be reached.at,[phone]. If you need additional information concerning this COC or the
General Perm" it.'please' contact Susan Cauley at [phone] ext. 546.
f �
e � •, i . r
Sincerely,
Kerr T. Stevens
cc: (Certificate of Coverage only for all cc's)
Randolph County Health Department
T-%Vinst5—n-S5lem.Regional-Office; V�ater_QualityTSection—
Randolph County Soil and Water Conservation District
Permit File
NDPU Files -

State of North Carolina
Departno of Environment and Natu ra lesou rces
Non -Discharge PermiDivision of ttApplier cal ity [R;4
Application Form 7 l fir]
(THIS FORM MAY BE PHOTOCOPIED FOR USE AS AN ORIGINAL) 14U
General Permit - Existing Animal Waste Operations G 719Non-9
The following questions have been completed utilizing information on file with the Dwpiionpeplease
review the information for completeness and make any corrections that are appropriate. IiVing
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered. r'~.
1. GENERAL INFORMATION:
EHNR
1.1 Facility name: Balser Farm `'�'�' ❑apt. D
1.2 Print Land Owner's name: Hubbard Baker MAR 0 2 24
00
1.3 Mailing address: 3113 Marlboro Church Road tp� s rate n-��j�ii�_
City, State: Sophia NC Zip: 27350 marlion g
Telephone Number (include area code): [phone]
1.4 County where facility is located: Randolph
1.5 Facility Location (Directions From nearest major highway. Please include SR numbers for state roads. Please include a
copy of a county road map with the location of the farm identified): Farm Location; US 220 N. from Asheboro to US 311
N. 5 Miles to Marlboro Ch. Rd. to left. 1 mile to Baker Farm Road on left go to end of drive.
1.6 Print Farm Manager's name (if different from Land Owner):
1.7 Lessee's I Integrator's name (if applicable; please circle which type is listed):
1.8 Date Facility Originally Began Operation: 01/01/93
1.9 Date(s) of Facility Expansion(s) (if applicable);
2. OPERATION INFORMATION:
2.1 Facility No.: 76 (county number); 10 (facility number).
2.2 Operation Description: Swine operation
Feeder to Finish
1900- Certified Design Capacity
Is the above information correct? EZyes; F7no. If no, correct below using the design capacity of the facility
The "No. of Animals" should be the maximum num er for which the waste management structures were designed,. ,
Type of Swine No. of Animals Tvpe of Poultry No. of Animals Type of Cattle No. of Animals
0 Wean to Feeder 0 Layer 4 Dairy
0 Feeder to Finish 4 Non -Layer _ 0 Beef
0 Farrow to Wean (# sow) 0 Turkey
0 Farrow to Feeder (# sow)
0 Farrow to Finish (# sow)
Other Type of Livestock on the farm: No. of Animals: _
FORM: AWO-G-E 5128/98 Page 1 of 4 7 6 - 10

•
LJ
2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system); 25.50 : required Acreage (as listed in the AWMP): 25.30
2.4 ,Number of as ons storage ponds (circle which is applicable). _ I r
1.5 Are subsurface drains present within 100' of any of the application fields? YES or NO . (please circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES o (please circle one)
2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, MRCS Standards, etc.) (Swine Only)
YES or NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited? c9 C9
What was the date that this facility's land application areas were sited? --�
REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
3.2 Two copies ❑f a general location ;nap indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP): If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit
application for animal waste operations.
The CAWMP must include the following components. Some ofthese components may not
have been required at the time the facility was certified but should be added to the
CA WMP for permilling purposes:
3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation.
injection, etc,)
3.3.3 A map of every field used for land application,
3.3.4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the W"UP.
3.3.7 The PAN applied to every land application field,
3.3.8 The waste application widows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.3.10 A site schematic.
3.3.11 Emergency Action Plan.
3.3.12 Insect Control Checklist with chosen hest management practices noted.
3.3.13 Odor Control Checklist with chosen best management practices noted.
3.3.14 Mortality Control Checklist with the selected method noted,
3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility.
3.3, l 6 Operation and Maintenance Plan.
If your CAWMI P includes any compponents not shown on this list, please include the
additional components with your submittal.
A2plicants Initials
FORM: AWO-G-E 5/28/98 Page 2 of 4 76 - 10

C7
•
Facility Number: 76 - 10
Facility Name: Baker Farm
f•;Y�RQC` �V�
14110
�C1�SE Qy
t� �
4. APPLICANT'S CERTIFICATION:
I, ����,� 4_ (Land Owner's name listed in gist%n���u}, attest that
ng
this application for�
(Facility name listed in question 1.1)
tra a an c
has been reviewed by men is accu omp etT f e�e est o my nowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
Package will be returned to me as incomplete.
Signature
5. MANAGER'S CERTIFICATI
Date 2
: (tomplete only if different from the Land G%vner)
(Manager's name listed in question 1.6), attest that this
application for (Facility name listed in question 1.1)
has been reviewed y me and is accurate and compete tot the best of my know ge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned as incomplete.
Signature
Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION ACID MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERINTITTING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: (9I9) 733-5083
FAX NUMBER: [phone]
FORM: AWO-G-E 5/28/98 Page 3 of 4 76 - 10

�,---, sz � w 1�rJ %�—®' tea--- •
G p
2T253 � n�• � 'A: � "h �. � °t+� � �►+ryfr� ��•' `��.' , `u�- 'ex33' �� i �' �- + FR r `� `I' � ��' '
$ S i r7 -'*rr
,r^ ..rT7L r, rr Er �7 }� CCLTRa pE ■ 0+ .*M.
�I_�Ir L;L r 6�M S 11p 4 e�ti TO 1t; 7-,
a f e =r-r�'.f.. A] fl R IN RNE� tXr Rr+T • e ` -� iL'y r9y h kr
r A ° iRirnrs �o os !.1 s g 4 RO awrtt"RR a•uuRG e� 0G
G �. • Y cor rr '�E - a a' gLRe +, b ° r. • Yu � uol 4 wc. t
$5 ° �•!� •. •• °ijrr • yy cry �rrcr or rvt"� T. tT N, 1''• s i Rc t:•i_ ,�r..,y ^• .' ., . --J--• i u nu` �` �r eV , � c � ' C r nu '. mac': a. �� �'t: .,. �• aD 1 L RA':L� °� r a .vtifEt �. roS ri tJ,N .. 'cG >nl", � ew'•
~ r� , . __ '::+r•:r Sq� � :LY * . ret ['Li ��. �u =gq AR L� F [r .' n
Lk
.,i ' ' RL ��, • `j ^ ' a �° y�-'"'"� .ler r as1„ +tt'-
�±yqr � R � 4 �A.,;.•... � .. Ir<° PR�v,hErr e• lam] -
;� G� ` Cy , r +LF+ �j'�`r7'a I " c t.fl .:fir•. r.
P !Ka "c y ; DWN
if a erlo)a I I"�"'
` `Z: b��o+1 i°r .mow SC � 11 K .jIl�`,�v • t .l� *� R „--J}CCav +� �r r ion '�..
.�`tMDOLOa
Y� N J I P �r, y r V}/1 b°C` ` kc C ■ ►t� E 4Ty+w a n -arl�� t v+`� • f Y: 4
0 car
'w „ '`E� R°Mt7C ■Y(p i" ; rUODr �� s' rp�: a•`d"' ! i'$1.:ti • o„tic
.a.
!!! ;pfRc � Sf• *a 4 ww+l`EP 7 +
eec.r • n'•�„��rs pI{, r c rM`r use. c` �' • •f,
q 1 r:Ma caR arer�Y.r �'C, 7.R `'. 9 � � � ¢ • ��R � i s �[. � F Nf'N "" `t. r t
. E �� � R?"� I �+ r1• �Ss �R��D, � Brivolt '!i �Y�=YI i wy r. ` �� ; .. .�` i°r;�1° b nt4r*�v,s x g'is ~s
p s'ONO R I .. y�R : ► y r , q c e1
stE+r u`►• � r..u� �' ��� ► R� ; �W11
i[ �* '�c�irrory [ •Rrb ' ,yar�. }yepR��' 4� ;+ ,� x rr�. h�r !`s•r 6 'R's'?r Wrar � � - r��/"'�rJ aar�'�r �r
.
1AR rr�ry ppRM1V"� •n [ u.r r 14 r YMi�rsr� cf R7354 '" CG`�hr +r+°fie p ~ c fT ail to
an H/ �a ° •r r iai' cow [7T F9 .'. F
r E 1a
�'X( a1LirR a t'�. �° , �� 4 47'F �+ Lt •gAry "eta' rr iy cy '.n K �i r.
• 4 .t • rr. ti v f } P rY� r, a+4 I I JFC re7 a
itl•yN ♦. �'cr err j 1 I+ 3 + �" ;� ��
,eC` �riti;AL t vE' .mot: 1 eta =� r- t. a •' i { # .: x r. � ++� O i5
,,+• o- ,�, ,at + I • ,. - i°tiso
¢ a"� 27317
ay u r F r Y "'OP i 1 �� f: .��' r• I 1 •_Y., ��. Is S `y • l
�ri}ril.f.4r +y7f 1.1 ,r t ;i +�',j it'' Sr, tl �- Fta���[1 °'a y�• i• o ��
0 'N S H I r� • ROY:M C]1 :r
* r+ IT ,r C.7 rK r f f ^, �,1 I r . x• i'r *^AFC//
ag h r1 DR
�Lr y "°" ! r aar- r -� r CRtrvlfl8 Nklll'a�Ca �Q
HAM D.D I ti +fr It � ► .h�t� ,
�+tl ti YOU7h CA r7 = c—
� � �D� ��� 1^�� iiRPr a f
C[AtljAID
Y S(7(f � �✓' s� � •1 P � w/ifi4°! r � _ _ j I f� Ti i I �r1:4{ n L
rrr it, r -E ■ 1R SDprwA 1 - prh r+ ty ji 5�,...i .. ,R•` O.
] X. [y 'Y►rApC / S tyL I� •£y L 7)!I �apLpM p ... r oo
I G6 tww r �yl �i :F '? ( R qC• e ' I `{ Ita n l'r�'++., •Ii::ai At,
r�p. �`T� m 1 e �� ' ��' +�� 1a•L i. iR�RRl�4�a
•fi�CR[rr ��, .. L4 � � Y°�r ti �atR 4 ^ ? Lea.-. � f `I wR � � },F'�
TRL 1 M`h • 1 I T WNSHIP A=M
-Ce�{daL�r Fa = x.
MIT a M •ur.tr f SlsvTp sr
'� ` wZ 4� •1 Grj'^"4rpa� rQ �ti Try + tie.frseP6r �YQL k'
RO 9 x ti PL' -40
x oe F�'�x �h M : s.rAna OZ
'°tia 4i�a9R�N S4 u=Ir�y rv. en { �p I e�KD,�� PF�
rJ ..
.I � a �T ry � A G8 I"4❑ �_orf a
x w g .Y• T WNSHIP
� �� 'rTD � � , � � t i � [7 ,I f J r• � f zFo-� smra.
& a Vdl!*•p sh
0 Y°Rwp
rAPFACON PAp sr,lt L+'ra Rp : . • ;" ` 17203 ■� r' I,
• RR �* St�ty i £ �� 5{RJSS1
v ~ 4 Ijr! F• C7
134
.r 1
IT
'.1 I Is h rs S �'i .e` -. �r'°iT � � % 64s4 r•_ .It CI � h'S
it y}
_�,�. +: •a: °p}SR'�`c'=�rr••°r" � r � iCir'{ � �s� :� „ 1 idLf,

ml well
z5e;
Xo�
9.1
ijw.
" n, r.
Ass
Lev,

K :+--fi t�i Sri= } :i�i7AE7o ri�R•C� ..CS1.i'��• ;� vs< r4•
ti.3 ; � 4 �.. �^•Y'e�• •,• �T�•.. �°' -•.: _,. .M;�••�,• R„ a :a% � •.:� ',,.... •,,r. ii:y�,+r�„ ,�
•�•�'Y �.:i�'yyRd►:. �. =�,ii: :;..?� �. ��.-. r1, i►:-"'�' � .',[•• - .��•.:. *t�,r. ••'.a�.': �-��. �...• ; . .+i1.•_.Ja.r•.,
"��_�r. ;f. Sr- ��f,� r•r :; ''R':� t�; •� q. 'il .,.- •' ••'• no- '�~r•�•�.'t,�'• ! ;+� •:' ,s.. �:.C� '�
� i:5. ,•�.�': ?�.>'"t•; .�f'i'l�e._ is ,� ^3'•`�� �*.F:'1•N w K+�' ,.r; ,• �.�.Si�fi:..* .e
'ZY:�':�•'1:y=x,~'•~•:'�,: i:}ifyi •*�:ar.�'}! .�i�� ��i .y� _' F' �'y't cs', r"1' p •7 r}.n
i �r.. ..:�� 1�. T.�q'• _Fr• ,�j��l; *.'+ jz
-A
y4• ;C•:Y� 7. ��*'+fir•' _ �f ���^r y 7i�' �y�`Y �r•��.r;.
Mai;.. ;R: >f+ k•4,'�• '?f, •,1 ^�.ir..�k r �T;117 ' : N.-. ,i Sd; -+!: .•
�r �rj • •},: ii-.r �,� .. a ! �! y: •�.. �� {�• ..r �1�'i. '.+s:.SC � • �'. �.. �k � Y'7.5' y'A :�S •C: :'
� ,�}.. x.. ,' .yew"•. '-:�*•,`�•••.• } - ?V!�� r .r7 .
�.. r•'� -x� �y" '� k����- 000!ll���� r • ',� µ ° N !.1-�'S, � - � �i z; �y,,,.r i •r:P y
.e- �rr'-`►•� S �i. �'�'ii+�-li..` � ii #:.. _ .-� v - fir �'7'y �'� 7. :i'. • :'.
rrt
`4 • t .... : , • �� � . � .rya ?+ •= j � . �� i•Y �. � �� Y�W�
csG ^i-'^�7 i �•`'`�� tVrr :3 h.�� ti7 IY��*i.� •1'��-'• •p
J�i�y�-'!r ;--wM:.•I.�i:;,,i*,"t, .M •�j11' x,,�.}ya.
isY ... .. .i 1». �r .,•. "e r. MJ` 1.:+ i= :is��.•r .� .f'.-C, •f , i •w ,_-,. i' F:. ' r'-y,
]� 'f�.. V •¢w mil'- x
4 . .- C ,l�27
��r:s • _ *y •i. r' i � �rsr. •r sr-�.ti ?�'-•
1a'2:
++;-•• ..:sue.. ;w � i�C�.ij�'�•:i ?�;-^r- � pry�.�,ii:+;�:.1.
44
co
mm
�; � � ,.,f i��, •� ." r.;"�':�T %���`►fig
.�. �'}�" C • � '� k- .'s-: it •� Ejr
..,�
.f "I", INK b Ar r+..A�=ar ' `•'� Tr1'a ' fa : , , t �'
i.., s{..: j r t. •. e. r t� t� r y �• xasi,
1-0 Ift
417, TWA
-► a x=' ���:.�' >z:.�
}}sir,• G$ !r• v"M , i�* f• ' d
' � i �'_Y sir. � L• . � :�i;:3LJ'G�7'w7rl��� •i�l:i�: ��:. •
PIP
ri" ray~ 7

0
ANIMAL WASTE UTILIZATION PLAN
IIIIIZIIIIIIIIIIIIIIIIIIIZIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIiIIIIIZIZI
Producer:
Location:
Telephone:
Type Operation:
Number of Animals:
(Design Capacity)
STORAGE STRUCTURE:
APPLICATION METHOD:
Hubbard Baker
3113 Marlboro Church Road
Sophia NC 27350
[phone]
Existing Feeder to Finish Swine
1900.00 hogs
Anaerobic Waste Treatment Lagoon
Irrigation
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops
in the.fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. ❑❑ not apply
more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall be applied to land eroding at less than
5 tons per acre per year. Waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10-tons per acre per year providing that adequate filter
strips are established_
4. Do not apply waste on saturated soils, when it is raining,
or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed
under DWQ regulations.
IIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIII
Page: 1

101MAL WASTE UTILIZATION PLAN
IIIIIIYIZTIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIII
Page: (page)-_
5. wind conditions should also be considered to avoid drift and
downwind odor problems.
6. To maximize the value of the nutrients for crop production
and to,reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more than 30
days prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. If
you choose t❑ change methods in the future, you need to revise this
plan. Nutrient levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from your
waste management facility. In some cases you may want to have plant
analysis made, which could allow additional waste t❑ be applied.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate changing waste analys-is content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
This waste utilization plan, if carried out, meets the requirements
for compliance with 1SA NCAC 214 .0217 adopted by the Environmental
Management Commission.
PAGE: (page)
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
1900 hogs x 1.9 tons waste/hogs/year = 3610 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
1900 hogs x 2.3 lbs PAN/hogs/year = 4370 lbs. PAN/year
Applying the above amount of waste is a big job. You should plan time
and have appropriate equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
IIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIII
Page: 2

,_ _.—.. _._�__ _�.r... r..��.. ra. .r.ns r...c...�—. � �+-..y..... v. �....i..�---......ct .� ...•siw.:JYLr.:-.. �.. —"'+ti:...i:J:i:.i:.=.'.�C.�.Y i:�i.S::..w� w�.. wa]:1:.R:...:._. .i
*,MAL WASTE UTILIZATION PLAN
IIIITTITIIIIIIITTTTITIIIIITIIIIIZITTIITIIITIIIITIITIIIIIIIIIIIITIIIITI
TABLE 1: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
-------
APPLY
RESID.
APPLIC
METH
N
TIME
274
1470
2(113)
Mc132'
FESH
4
200
0
1.16
I
AU-
NV;FB -MY
1470
FESH
I510
�2(23)�MeB2
�4
1200
10
�2.55
AU-
NV;FB-MY
1470
2(3)
Mc132
FESH
200
0
2.96
I
�4.
1592
AU-
NV;FB-MY
1470
2(4)
Me22
FESH
4
I
1200.IT
13-96
1792
AU-,
NV;FB-MY
1470
3 (1A)
Mc32
BERH
4
0
I
1200
11.16
1222
May -Aug
1470
3(2A)
McB2
BERH
4
0
1.37
I
1200
I
1274
May -Aug
1470
4(5)
BaB
BERH
4
0
li
1200
13.72
1744
May -Aug
1470
4(6)
BaB
BERH
4
0
I
�200
13-51
1702
May -Aug
1470
4(7)
BaB
BERH
4
0
I
1200
13.G9
1738
May -Aug
1470
3(la
Me92
SG
2
0
li
1100
11.16
�116
SEPT-MAR
1470
'3(2A
Me22
SG
2
100
Q
I
1
11.37
1137
SEPT-MAR
1470
`4(5)
BaB
SG
2
0
I
1100
13.72
1372
Sept -Mar
IIIIIIIITIIIIIIIIIITIIITIIIIIIIIIITIIIIIIIITIIIIIIIITIIIIIIIIIIIIIIIII
Page: 3

1470
1470
---... _.._...� ..,.......r....� . �—.,..t... ..-:a.:.. T....y..aw�.te.:au: �:�•.�.,aii:..,_.:�..r�e�y..::�.c....:'.,,:...>.::.w ..i.. ,.�.. ...w�:
91MAL WASTE UTILIZATION PLAN
IIIIIIIIIIIIIIIIIIIIYIIIIIIIIIIIIIIIIIIIIITIIIIIIIIIIIIIIIIIIIIIIIIIII
�4(6) IBaB
�4 (7} BaB -
END
SG �2
I
SG 2
I
z f
100 d 13-51 1351
Sept -Max
100 a 3.69 136-9
Sept -Mar
TOTAL16193
Indicates that this field is being overseeded (i.e. interplanted)
or winter annuals follow summer annuals.
NOTE: The applicator is cautioned that P and K may be over applied
while meeting the N requirements. In the future, regulations may
require farmers in some parts of North Carolina to have a
nutrient management plan that addresses all nutrients. This plan
only addresses nitrogen.
IIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIYIIIIIIIIIIIIYIIIIIIIIIIIIYIIIIIIIIYIII
Page: 4

..... ___ .._.. - _.__.-.--._._�.___ �_.+`� y,.n_ �w ..f+• w+�.....+..:2�.s_G•._...r.ii+-4..�'.+�r:`.�T��+�:n.w:.++i.in.F-i•...r:i•.rV•i.ntiYC....:�.y. «W.
01MAL WASTE UTILIZATION PLAN
IIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIII
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached_) _
(Required only if operator does not own adequate land.
- . See required specification 2.)
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
-------
APPLY
RESID.
APPLIC
-
METH
N
TIME
END
TOTAL10
Indicates that this field is being overseeded (i.e. int.erplanted) ❑r
winter annuals follow summer annuals.'
In interplanted fields (i.e. small grain, etc, interseeded
in bermudagrass), forage must be removed through grazing,
hay and/or silage. where grazing, plants should he grazed
when they reach a height ❑f six to nine inches. Cattle
should be removed when plants are grazed to a height of four
inches. In fields where small grain, etc, is to be removed
for hay or silage, care should be exercised not to let small
grain to reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too
high and this will definitely interfere with stand of
bermudagrass. This loss of stand will result in reduced
yields and less nitrogen being utilized. Rather than
cutting small grain for hay or silage just before heading as
is the normal situation, you are encouraged to cut the small
grain earlier. You may want to consider harvesting hay or
silage two to three times during the season, depending on
time small grain is planted in the fall_
The ideal time to interplant small•grain, etc, is late
September or early October. Drilling is recommended over
broadcasting. Bermudagrass should be grazed or mowed to a
height of about two inches before drilling for best results.
** Acreage figures may exceed total acreage in fields due to
overseeding.
IIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIII
Page. 5

0
MAL WASTE UTILIZATION PLAN
IIIIIIIIIZIIIIIIIZIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIII
lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and-2 above:
CROP CODE
CROP
UNITS
PER UNIT
BERH
BERMUDAGRASS - HAY
TONS
5o
FESH
FESCUE - HAY
TONS
50
SG
SMALL -GRAIN OVERSEEDED
TONS
5o
TABLE 1
TABLE 2
TOTAL
TOTALS FROM TABLES 1 AND 2
ACRES
LBS AW N USED
24.08
6193
0
0
24.08
6193
* BALANCE
-1823
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffers, filter strips along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than the
acres shown in the tables.
See attached map showing the fields to be used for the utilization of
animal waste.
IiiiiiiIIIIIIIiiiiiiIIIIiiiiiiiIIIIIIIIIIiIiiiiIIIIIIIIIIIiiIIIIIIiiiI
Page: 6

. ._____._—_""_'........�.n.w.r......-�.._.. ___.�.ti_w.w++�_.� .�.r.. .....e��i.a,..L.�I�w"➢L[4•."...ti'.S"r:��rryw�r.��i�r y it i' .- - -ur.i
. l
93:MAL WASTE UTILIZATION PLAN
IIIIIIIIIIIIIIIIIIIITIIIIIIIIIIIIIIIIIIIIIIIIITIIIIIIITIIIIIIIIIIIIIII
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient
rich and will, require precautionary measures to prevent over application
of nutrients or other elements. Your production facility will produce
approximately 703 pounds of plant available nitrogen per year in the
sludge.
If you remove the sludge every 5 years, you will have approximately 3515
pounds of PAN to utilize. Assuming you apply this PAN to hybrid
bermudagrass hayland at the rate of 300 pounds of nitrogen per acre, you
will need 11.7166666667 acres of land. If you apply the sludge to corn at
the rate of 125 pounds of nitrogen per acre, you will need 28'.12 acres
of land. Please be aware that these are only estimates of the PAN and
land needed. Actual requirements could vary by 25°6 depending on your
sludge waste analysis, soil types, realistic yields, and application
methods. -
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the
soil at the time of irrigation such that runoff or ponding occurs. This
rate is limited by initial soil moisture content, soil structure, soil
texture, water droplet size, and organic solids. The application amount
should not exceed the available water holding capacity of the soil at the
time of irrigation nor should the plant available nitrogen applied exceed
the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables 1 and 2. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application
rates and amounts.
Tract
Field
Soil Type
Crop
Application Rate
(in/hr)
Applic. Amount
(inches)
1470
1470
2(1B)
McB2
FESH
0.3
*0.75
2(2B)
McB2
FESH
0.3
*0.75
1470
2(3)
McB2
FESH
0.3
*0.75
TITIIITTIITZTIIIIIIIIITTXSTIiTIIIITIIIIIIITIIIISTIIIIIIIIIIIIIITTIITTI
Page: 7

OPIMAL WASTE UTILIZATION PLAN
IIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIiIIIIIII
1470
2(4)
McB2
FESH
0.3
*0.75 -
1470
3 (1.A)
McB2
BERH
0.4
*0.75
1470
3(2A)
McB2
BERH
0.4
*0.75
1470
4(5)
BaB
BERH
0.4
*0.75
1470
4(6)
BaB
BERH
0.4
*0.75
1470
4(7)
BaB
BERH
0.4
*0.75
1470
`3(la
McB2
SG
0.3
*0'.75
1470
-3(2A
McB2
SG
0.3
*0.75
1470
4(5)
BaB
SG
0.3
*0.75
1470
4(6)
BaB
SG
0.3
*0.75
1470
4(7)
SaB
SG
0.3
*0.75
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations, the application amount shown cannot
be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 1.80.00 days of temporary storage and the
temporary storage must be removed on the average of once every 6.00
months. In no instance should the volume of the waste be stored in
your structure be within the 25 year 24 hour storm storage or one foot
of freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply the
correct rates to the acres shown in Tables 1 and 2. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may
make this plan invalid.
Call your technical specialist after you receive the waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate prior to applying the waste.
ITIIIIIIIIIIIIIIIIIITIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIITIITIIIIIII
Page: 8

' � t
91MAL WASTE UTILIZATION PLAN
IIITITITIIIIIIIIIITIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIZZIIZTIIII
NARRATIVE OF OPERATION
This operation is owned and operated by Hubbard Baker. The operation -is for
1900 feeder to finish swine. All waste is applied using irrigation. This WUP
uses fescue hay, bermuda hay, and overseeded small grain as the desirable crops
for absorption of nitrogen at agronomic rates. This plan demonstrates that
sufficient land is available for the proper application of the waste generated
from this operation.
ITIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIII
Page: 9

WASTE UTILIZATION PLAN
IIIIIIIIxTIIIIIITIIZIIIITIIIIIIIIIITTTIIIIIIIITITITTITZTTITIIITTIIII
REQUIRED SPECIFICATIONS
�. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must -be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (see Fui-G standard 393 -Filter Strip)
S. Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
G. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. when applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not t❑ exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
t❑ control odor or flies.
8. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied ❑n actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhabit growth. The potential for salt damage from animal
waste should also be considered.
Page: 10
IIIIIIIIIZZIIIIIIIIIIIIIIIIIIIIITITZIIIIITITITIIIIIIIITIITIIIIITIILI

O
WASTE UTILIZATION PLAN
IIIIITTIITITIIZITIIIITIITTIITITIIIIIIIIIIITIIIIIIIIIIIIIITITIIIITIII
REQUIRED SPECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted -to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995_ shall
comply with the following: Theiouter perimeter of the land area
onto which waste is applied from a Lagoon that is a component of
a swine farm shall be at least. 50 feet from any residential
property boundary and from any perennial stream or raver (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be'applied closer than'25 feet to perennial waters.
(See Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer thank100 feet to
wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly into water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
the site.
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 11
IIIIIIITIIIIIIIITIIIIIIIIIIIIIIIIIIITIIIIIIIIIIIIIIIIIIIITIIIIIIIIII

WASTE UTILIZATION PLAN
IIIIIIZTIIIIZIIIZZIIIIIIIIIIITIIITIIIIIIIIIIZIIIIIIIIIIIIIIIIIIIIITI
aEqQQUgIRED SPECIFICATIONS
18. If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan' which will eliminate the
possibility of an illegal discharge, pollution and erosion-.--
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22. Waste shall be tested within 60 days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when these
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be
maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North
Carolina regulations.
Page: 12
IIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIITI

ANIMAL WASTE UTILIZATION PLAN
IIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIII
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: Hubbard Baker Swine
Owner/Manager Agreement
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity ❑f the
waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
North Carolina Division ❑f Water Quality (NCDWQ) before the new
animals are stocked. I (we) als❑ understand that there must be no
discharge of animal waste from this system t❑ surface waters of the
state from a storm event less severe than the 25-year, 24-hour
storm. The approved plan will be filed on -site at the farm office
and at the office of the local Soil and Water Conservation ❑istrict
and will be available for review by NCDWQ upon request.
Name of Facility Owner: Hubbard Baker
Signature: Date
Name of Manager (If different from owner) :
Signature:
Date:
Name of Person Preparing Plan: BARTON ROBERSON
Affiliation:NRCS Phone No. 336 629-4449 (Ext 3)
Address (Agency): 241 SUNSET SUITE 105 AVE
ASHEBORO NC 27203
Signature: Date:
6 !1
IIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIXZIIIIIIIIIIIIIII
Page- 13

..w..�rw.as .v.�.r•.r.Oyu.wad..r.-=,...ruN•�^+'�++...iL:::.:ii::��:Ja1iiS�w'+waJwa:+wl.ti.:na'w:.7i'.S:isN'`�.•.�-1'.':t:_rf:n.�a..-.'.�,•...-'.5:i.::::��:11.i=.�'�SW r:.�.ii::y
ANIMAL WASTE UTILIZATION PLAN
IIIIITIIITIIIITIIiIIIIIIIIIIIIIIIITIIIZIIIZIIITIIIIIIIIIIIIIIITIIIII
ANIMAL WASTE UTILIZATION AGREEMENT
(Needed only if additional land has to be leased, etc.)
I, , hereby give
permission to apply animal waste from his Waste Utilization System
on acres of my land for the duration of time shown below.
The field(s) on which waste can be applied are shown on the
attached map.
I understand that this waste contains nitrogen, phosphorous,
potassium, and other trace elements and when properly applied
should not harm my land or crops. I also understand that the use
of waste will reduce my need for commercial fertilizer.
Adjacent Landowner:
Waste Producer:
Technical Representative:
SWCD Representative:
Term of Agreement:
Date:
Date:
Date:
Date:
, 19 to
(Minimum of Ten Years on Cost Shared Items)
(See Required Specification No. 2.)
IIIIITiIIIIIIIIIIIxTTITIIIIIITIIIIIIIIIITTIIIIITTIITIIZTTIIIIIIIIiTI
Page: 14

ANIMAL WASTE UTILIZATION PLAN
IIIIIIIIIITIIIIIIIIIIIIIIIIIIITIITIIIIIITTIITIIIIIIIIIIIIIIIIIIIIIEI
STATE OF NORTH CAROLINA
COUNTY OF
I,
Public of said County, d❑ hereby certify that
a Notary
personally appeared before me this day and acknowledged the due
execution of the foregoing instrument.
WITNESS my hand and official seal this day of
19
My commission expires
(SEAL)
0
Notary Public.
IIITIIIIIITITIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIII
Page: 15

wo-,.++..`r'++:�:.:r....1sL:siwi}, r y...r. .....rw-yw.4�.v.. �........ .... _.._.,.�...r�....r..--..ww ..... �� t.._.. ... ..... — ..—._
ANIMAL WASTE UTILIZATION PLAN
IIITIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIIITIIIIIITIIIIIIIIIII
Waste Utilization - Third Party Receiver Agreement
hereby agree to apply waste
generated by in a manner that meets the
Waste Utilization Standard (633), or use an alternative waste
utilization system that has been accepted in writing by the
Division of Water Quality.
Third Party Receiver:
Date:
Term of Agreement: to
(Minimum Ten Years on Cost-Shared'Items)
STATE OF NORTH CAROLINA
COUNTY OF
, a Notary
Public of said County, do hereby certify that
, personally appeared before me this day and acknowledged the due
execution of the foregoing instrument.
WITNESS my hand and official seal this day of
, 19
My commission expires
Notary Public.
(SEAL)
IITIIIIIIIIITIZIIITITZIIIITIIIIIIIIIIIITTIIIITIITIIIIIIITITITITIIIII
Page: 16

M•�j'" �.. .� �a'1. `�.11,i �' d
q0lll�.
� `��..--•,•-��,, s� ' :! i�.T,Sy Y , GJ •� L/~� yr 1 � �
S: .cx;' .. ,r:•:.- cw 7i�'L:.. .•, 5.� • ,R -Snf. �• "�'( .•�� ��. '�! 1"
t- _*�,tx..r. . �: •��"ti ��z::�-SY�',� ;_�w�t.;i;� .:,,:rr:: �'� ram' �:.
} ,rlr`}� n ,1 a :'�. r y. ! K' . - • 1 �y •' h
,.. i., - 5•��ry -- � Ask , � }� 'F-
.. R,f,�}:• r •art. � '� ' t
��' r u5: �F"e-• � � .r�i ¢ jai .�
AA
Wk
• •r; ((,,j���,�j`yy��JJjj r--a-���'`?f: mot. K
'.��v T�+f; _ •�i; _.: 1a ,k :4 ••i •: ''Y~_r '3sxi: I Y. 4' 'S
5. v 1w•1.. �� ii,: ti' i-•r+��•t •1� .�` 7 4•' 'S '�' 1: �, ,`` r!
W-4V
f L `..#'� ram• �M1 � J �•L.' c � {•+'�a4 -�.' E 3 31 ' �j, i, �
lt; - - 1. _ 1 4.E. • { -
OkA
-v "' �• !�'• .�' ;:``�' ,� ;� .tit•
r� r. ' y' 'w` �T• r { ��..�.. may., •'r'yL[-y l.�z. K `„"'t rAN
I
r.-'. i• 1� •�5.

RANDOLPH COUNTY SOIL AND WATER CONSERVATION
I OPERATION AND MAINTENANCE PLAN . "may
PROJECT/FARM. Hubbard Baker
DATE: November,1998
+ A 4" x 4" treated post, painted white or a 4" diameter schedule 40 PVC pipe with cap,
or any other method of permanently making the designated height shall be placed at
the maximum liquid level at elevation 96.7. At no time should the effluent level rise
above the maximum liquid level, which is 1.8 feet level below the settled top of dam.
A visual inspection of the waste storage pond will be performed at least twice a year.
The inspector should check the condition of the dam and the emergency spillway.
The inspector will need to look for signs of slope failure and seepage on the back
slope and at the toe of the dam. Also, a very close look will need to be made to check
for signs of damage due to varmint (ground hogs, muskrats, etc.) burrows. A visual
inspection should also be made after heavy rainfall events to ensure that the structure
is not experiencing erosion rills or gullies. Any problems found should be brought to
the attention of the technical specialist for repair recommendations.
The waste storage pond will need to be mowed twice a year. All eroded areas shall be
repaired and stabilized. Areas that do not have an adequate ground cover shall be
reseeded to provide vegetative cover sufficient restrain erosion. The dam and all
constructed slopes will need to be fertilized annually with 500 pounds of 10-10-10 per
acre or its equivalent.
• Maintain all waste handling equipment —pumping, Ioading, hauling, spreading, etc. --
in accordance with the manufacturers specifications.
All waste application shall be completed in accordance with the waste utilization
plan. The waste storage pond will be emptied at the end of each design storage period
(L80daysor 6 months) or as needed due to excess rainfall.
See the attached NC Agricultural Extension Service Agri -Waste Management
Publication by Dr. James C. Barker for information on sampling and testing of the
effluent.

•
•
R.-UNDOLPH COUNTY SOILAND WATER CONSERV ATION% DISTRICT
II EMERGENCY ACTION PLAN jl
PROJECTIFARM'. _
DATE: 1 z- 31
• "Contact the North Carolina Department of Environment, Health and Natural
Resources - Division of Water Quality - Winston-Salem Regional Office at (910)
771-4600 if the problem occurs Monday through Friday between 8:00am and
5:00pm. If the problem occurs outside of those hours contact the State of North
Carolina Department of Crime Control and Public Safety - Division of Emergency
Management - Raleigh at 1-800-662-7956 or [phone]. Provide the following
information:
FACILITY NAME: Qkk. { + ^
LOCATION- 303 m0.,1�v*v 0k�w,+ fCO..5op►•4*, A;C Z73S°
REGISTRATIONIPERIVHT 9 IG-10
+ If there is danger to human life, downstream residences, roads, etc. call 911 of the
RANDOLPH County Sheriff's Department.
• Begin lowering the liquid level in the pond by applying waste water to nearby '!
irrigation fields if possible.
• Contact a contractor to begin repair of the problem to minimize off -site damage (list
the names and phone numbers of three below),
Me ' I &1
i 1:
©
Sri a s
p.
r
/.
• Contact the RANDOLPH Soil and Water Conservation District at _(336) 318-6490,
• Contact the technical specialist who certified the waste storage pond . If this
specialist is no longer working or is not available, contact another technical specialist
who has design approval such as the Area Engineer.
NAME
PHONE NUMBER
Shaban Kali, PE, CPESC
[phone]
Jerry Pate, CET
[phone]
Daphne Canner, EIT
[phone]

IF D R
r+. `ter« _ I _ -- `c —.�- `t �r ;-►� s L U N' i
27253,.
� *o � ar`s t c � a £. k + � ., l � `'iwt - ~G+■�O, °, �� , �� a°tl/r9c r:
.. i;-• OPo1 7q T71 Rr °'� C(ILTAAke y < <�' , LE Y ELcC �r�";No p*7 •T■ "a. ' Q B r f . ' 'a �� 'tr `J I
r' G�Ic "rr4�•"�.•:- cza
ILL7 {.[�Er �JJ ['IKC EIFP'CX,:J kOCKEr• wryT.f `^ ^ RF `Pf n��
rjfM.�iR�-tNlsr hY `ZRD etea.pere # RIeN,Re �r ` T
I" wor A7 �. Tv :Dr r, � '(. ,�,. ■ r Ra r'� R['7Tr rJ_ i- ix C:SCh' AL � �t
t •' • - r �' +-ti 5+c +v �yL 'so 4+rhi L'YE� F Ks• r LL ; a wl 5�r.^4r.c yy
LA rFll.. T rr4 4f�+raL y1,/0�55r�l -'� iur� C= t.n' •C'='
lF LfLL � C neat? re S t^l ou C$RANS r Ear++, : l" r� L.• 1
rR°.:"o°M +}p`.:F'�a ^ rrp 4■c �;, 1.l �Mr r. rc.e� y `+e'
• �t� �•�. :i • '.o s i� W .a� x = •'a r'� a €oE = ��o., �• r pp y J- Iv- •4-1
I •J ;µ*Or ;° `_ SORDLET i x y9 7Pe [f �A4rr ry rrhD ' 7 GnOLa Aar a PROVIaFN [� v�■. V p ��_-�
La[t r' `r 4v a .e1 YRJ13. CED4RRp.
i a [ J s .k�� r �r£t OWN 9_ rso s d u.4 ai J
I� : l M c`�L%ot► 'ter ,oa.?. �G enola -yam n a i..Lr�rk
C311[J(,�J•_ c bus - - CHulz .
CLR Rr ° r N ea OaaR � .-�� � w � E ��?•��`'�
TOWN IP F�L '"*� '`"a�� g� �' e° ro EL .• RC"TL �.,.w r� mw.. t .�
•�•
L. e+ rf♦ i a■Gy ¢ s cy r
rla r
LLL
°"RMp
Wrl ITE6dii�s s ,:�' �,mo•�wj.t X�4wLL
PETEA
=ie3" Ltc�c7. - R �• [ rN_ +' vs1r+ { .rt v IrC ST • fh I Q o rLa N pF CK- H d' yw,vaC; µ .,t.
}a ► rY+ CVf fir. "
r•'N } rrtL CaLTP+.Q•+�1 R re � e^ ; t1E
* to 5 Ra ,�' i Y.i _ r'•i `` `.
{j Mfi4N[ � y �F +r� W s.lo[� 3�] .�ew 5
ae!'r,. l �yY[T S5 1Ra .--�+M1arket LLGR A'[S
(/r{. NOT e� O L' LOrL,r tq�L *p + !r w Na rSYIE M y[[Sa* :•
Y kLLETRL
ar•- 7 SOIr�" 2 E [.[ is Aa i e L`j y dOn! aN •Y� _ i RL.
�w OR. D O� � - C ♦ } 2 �!a ra 5 iLL:L !' R.
4LIA jw![Nlfw R % � � "' � • rLL 7 FM � . � 9 RQ C � \ P
v r*f L" * yr. R6� .roc■ - c G 2 r 0' y L i sal°4 1V�; G� ■P
r r tii' a.En F' .4uoGL,o.r EpR�y^ :► e r RLxc•• n r� fi s r[ Is, 6.+�` ¢I `
r C D[ : r,E 4 •_ oo rpp� tY. r p t s t • a.t d s! �- °° s
e= � KfR YrLI
' ■ RIJY.GR (• � remi yl h.�; R++ [y '� � L Q [ GT I
i wptl� lac. pl a ❑ I` • 1 n ` ~ 1'r CdM�LT a �C` ATl"� ¢F �• L I ;^ .N, 4 [y i�
igRpi •"y wt4 = ' °,.z7350 v4` R� r.
�:r L, ■ 4ti� ,.�^ G ^rt o iAt
� ! ,�Fa " o'er `• La + rr r ' �
��'yI•f rxLna - �� !t L 4 b t c�R4. • } °{�rL 5' raL I � JaC � rr.
rrals[OR LSVEL
4 IL 'tR�r cr RL+ i P. ,TN1LIr! I' s
Sw °E �^
o■ W �RAA •e.«, ,. , 'GL}l�-.r4.r + Rop'�la
i'❑ Y,YiIL(La C AD. rriR it P�f� : ti' WL. utL'� y ! ♦"� �y 9� 3T, ' ' KaInTfMemma
7 I�. � t e�L• I4D ti [a �` r.-.r� T, F: F �°� � ° {�}Yi r:° v � I ,yy fqr G
t�■tR Iif]i i 1 i r ^ .^ } [ L; �' j d ..r.• '1 k'Jc. r v[ :( �9
♦■ a�. C v N - L I C� 1R"l'110 `* ,a ..r yc v P:.tt ■p� - +R,S �+L� rl I
klL� ff+ r
4i 3 D I Y..7 ]o tv [ +D177M q'�
I G' krI
�I r . A rMk �,, c ti p rrc AR �� a■ r Drsr �'_ _ oc �- orinville M1111 /o o L�1'
i IF, 04* I C
TO[STM
o 4 •Rp. `.. LLL....--���"'11e if�o .�- �{4AL� 0. ran•-
CA�G wLRAA'[1 j f 7• r�FfRJ� r1%5T J rGry ❑
w£srs r - 2 i
~ � & jy� � u "T'�' � -Ea - t}w �x C � ^ saaxl►. 1 /'. �£ 1 PINES �- - � I f+ r r ■ � � L
t7 z +D NFlpFO ►. L.O ��Qjj �[ i f RA Npi4FAIA .i „ Orr" �r� A c $ •
�t n - :1 - f7 e4 r w �I T R! C� J r: + `"1L[lar ry.Mr
❑ r N I NIL!
+K 1 rAO£RnAt.( 1 i 7 a RA[L �' i ! L•rL r tR033wi
: ! �ti nkr�
7� �tiw SHEP�IERD Fp c+r+ %IL•M Ro. SL„•
voc
TA• 7" l"rs, I Ln. r in •°r. E T - iat7k� i u'
ATRLR ti:TN i1w. R4
VV a r
a T W ,NL - r£!w Cr O fi C7t L
-G,6dar Fa
9 M rj,■u [r 9 0 O S ' Bit IL,LIS r I p,C�
i, s! ■ EKS T y - 4�T. A tN
v, ! Ap. O w kVr'r'ra
GwLS pR Sit ViR 5 .1 FQ ��� �. _ - 27230 a • PO' mac.
At[RA
tp, SQ Rf1. 1� �. �lAS 73rt1t• t.pG J 1'
,qq+ r p r'YT g
•F •' `
•� 4 L KE L.
'A1R A'• 0 C �'
LUCAS
�s a" d RLLrRMt
+lRkA r oi• ,� ; tl i Cr pR 14 ,,,`_ RY% p� -^'. i
AI[}rGLL.. RIDLE ? `rrL p 2 r 4 L£fr ! .:-ram•• /� {] Clp L i grp
tLEN: I"r I✓L.7 D
T- WNSHIP �• ; I i s J 0 Ln '� i LrEann.
Q _4a� o fl �• 1�1 II o� $ ITRkY
ILAN
• c ` - ,. R�o � a'7 .aa � i n } i J it �4 ; eCao- � M perlr,�
r_ a st q+�■ i , ww} yL. trRLl r:
Q
e �a
❑ „ S¢ L y ! 'P. SALrsaV qT I R wEOW"
shy o }I `•=t I ,�,RE,:
-�- FARA!R PRO wRLs GrlS Rp - I 27zQ3 �_ 1 1 Y c E
RP `• yldttS ..' `III �a 9pf' pPa 'PQ
A, CEDAR G DV 6
4
ro� n iL M1LL S i b y 6 4}• r i it .r. l• 64 I //
_Va - '[ •� 6 '� 0 ` •r . «i~ - . { Ft' .�• -L.
�Y'VR�N
OLD N c. n v a 9 F! R.c.c.
2.2
+ = 3 �:� `%o� i _i♦i 1 •Hr,- EeeQl¢ u[L� �P[7o1::`
rjti s
F"� rr� ~G• ' P' .. ° yG"` ors � R%o}, a ■■� '�`�`. l�'v } r :i o-

Swine Farm Waste Management Odor Control Checklist
Slim
Cnil$L'
13111f's lu fliiuiuti�c Odor Site 5pcclfic I'rndicc.5
l nl 1IMCiul
Swirle ploductioll
Nr
VcUclative or wooded fluffels;
f1
Recommudcd bcsi inamagcmenl pmcliccs;
SY
Good judgtncnl and Conrinorl 5cnse
Aiiill wI hody siisIacus
Dilty 111:111n1C-CUVCIed allimals
__r
Dly flools
I' oul smlilcus
i�
T1
0. Slotted iloolS• •.
� � !� •1i +
•
•
!
—, /
�.F'
.•�� it
waIcIel5 Ivc;dCE1 tjver's[oIIed fIooln;
Cl
i•ccdcts :it thigh Cold of solid Hums;
Cl
Scialle limiltue buildilp Iluin fluols;
❑
UjicIcrfloor ventilation for drying
maillue colleclion pits
Uriue;
lcgticllt m almic removal by flush, pit Iccharge•
•
11a11inI n1iL'oubia1 [ICCi}n1f1l1SH11111
or scialle;
Cl
Uilderfloor vcnlilation
ventilation exhaust falls
•
Vololile gases;
F-
hill limintellallce;
Dlist
f3' l?ff cieni stir monnicni
IIIEltiol• slllfilCCs
•
IMM
washdowII bcI%vwi gooup..;ofalIinulIs;
❑
f CCi1 addltivcs;
Cl
Feeder Covers;
•
❑
1'CCII dclivc y clumispom extCfldClS lu rceder
-
-
CDYCIS-
_
Flush laliks
Agitation of`iccycled fagovu
C1
Flosli Iaiik covets;
ficlidd while Ia11ks 71c filling
Cl
l;xtenti fill iincs to ucar hot tons ortnoks wi111
,lilt i-sillholI VCllts
I•Itish alleys
■
Agllation duriltg wastewaler
C1
Undcr11oor flush wilh omiciIloor v co I i I M imi
collveyilnce
I'it ICL:Iins gC floill (5
•
Aldttillon (lrrcc)'cied fagnolr
L1
Extcod Icc1111lge Imes tD near bulIoil i of 11iis
illplld while Ails are filling
WWI ann•sillhon vents
11 stilliol15 +
A I,-i (m ion Ell iiiiig5oii11) tilllk
S1I111111i1111: CoYCIs 4 l' •' 1 !�
f l l lllig Told th a►vilown
Citil5ide dinin Col1CClion
•
Agitnflvii during wastewater
❑
[lox covcls
or jtruction 1loxcs
convcyrlllcF
Ah10C..-J-1,ivember 11. 1996, I'oge
1
3
•
•

5unrce
t.,illise
11i1'iE's Iu i17111i11l17,C (]lull' SirC SIFCCiE1C E't':ICI1CCs `
bill sinliolls
0 Agilalnln )hiring sllnip Imik
Cl
Samp milk covers
filling alld di'llYllowli,
I-Ild ofdFainpipes al
0 AgilaIion dill ing ►vnsleivalet-
❑
1:xlend discharge lit) inl or pipes itndcnlcati)
Ingoull
Cullvcynllce
laguoll liquid level
I.agoul) Sulfiaccs
• VulattIt; gas ul 11 issiolls;
11I01cr liigouil hllllld Capacity;
• Iiiulugicnl Mixing;
❑
Cot IccI IngoulI sInIlit 1) Ill occdmes;
• Agilatiuli
❑
Mininlunl surf Ice at Ca-to-vulull1C IaIiu•
,A
dMillinnnll agimdun while pluti1)itig; ,
Cl Mcchallic;ll nclatioll;
171 Pruml biological additives
bligaliun slniliklcr a IIiglI Ill csspIC .lgilaliul1; V, IIIigale u31 dry (klys will) 111Ile w' I►u wind,
I1ozzic5 • willil drill C1 I'viiltimtlm ICCO illiCllded opelatillg plocCdllrc;
YJ hill ill it11A.e Clem- lagoull II(luid sni face;
❑ I'll till) ri om srcund-stale Ingoon i
Dead birds 0 C:ucass decurlillusiliutll ❑ i'lnl)crtlislu)sitiuu ufcaleasscs
Dcad bits disposal Mils a Calcnss decollipusiliurl; ❑ Cullip1Cle cumitig+ of calcasscs ill bnlial pits;
- ❑ i'lol)cr lc)caliwllcnnsRrncliun artfislluslll l)ils;
'. ❑ DisIlos;II IIIt Covels light filling
Sland itig Iva lei, arOut ld • 1ntIll upci diainage; CX UIidc and lalidScnlle sitch 11tat %viler din lits
raciIitics Miclubial decomposition of away liulll facilities
clignnic Inallcr
Mild Imcked oll(o public I'oolly In;Ii1Oninctl access Iunds 19' I'mIit access iDad ma1I1lei iniice
roads frnni Sarin access
�Addiliunal illrorinaliuil
I'uullty lvlainim Matiagemew ; 0200 Rule/111VIi' racket
Poullly Laycr 1'roilticlioit facility Matime Managemclll: Eligit Rise, Dcep Pil ; EIIAF 131-88
110111try Laycr IItoductIon Facility Manure Mai tal;crllell r: Utile rcnge Flush - LagooII `1•rcall nell t ; E13A13 1 J 0 - 8 8
I_pgnun Design and M.-magentent for Livestock Manure `1.lcalincnl and Sromge ; LUALi IOJ-8J
C, Iil?-at ion of Marline alid Wastemil cr A11pIiCmtitlll I'qull)nlei it ; Ii13AI Fact Sheet
Troller Disposal of Dend Poultry ; PS&T Guide No. 19
Nuisance Cunccins i I I Aitill IaI Mlit) Ill c Malulgcnlcl11: Odors and Fiics ; VKCI107, 1995 Coll fcrcricc Ill oCCcdi11gs
AIvIOC - Novembcl 11, 1996, Page 7 -
Available Flom :
NCSU, County Lxlension Ccnler
NCSU - 13AE;
NCSU - E3AIi PIP
NCSU - IJAlz
NCSU - I3A1?
NCSU - 1'oi1111y Science
Flotilla Coopcinlive Extension

Hubbard Baker
Insect Control Checklist for Animal Operations
Source Cuusc DMZ's to Control Insects Site Specific I'rneticcs
Liquid Systems
Flush 0111CIS • Accumulation of solids Flush syste111 is designed and operated
suflicicnlly 10 remove accumulated solids from
guucrs as designed.
Itcmave bridging ol-nminiillit cd solids at
discharge
Lagoons and fits C1 LIS1Cd SOIids Maintain Iagoans, SClllillg basins and fits tYhcic
pest brecdiug is apparent to minimize the
crusting urso] ids to n depth of rio more than G -
S inches over mare than 30% of surface.
l.xccssivc Vcgctaiivc Uccaying vegetatiuil d Ma vegetative control along banks of
Growth lagoons and other impomidnicnts to prevent
nccuululation of decnying vegetative ntaltcr
Mang walcr's edge oii impoundincnt's perimeter,
I?ry Syslcius
Fecdcrs heed Spillage ❑ _ Design, operate and maintain Ned systems (e.g.,
bUi1kcrs and troughs) to tuinimize [lie
accunlulatiou of decaying wastage.
Cl Clcan up spillage on a rotidne basis (e.g., 7 - I U'
day In(crvnI durnig summer; 15-3U day interval
during winlcr).
Fecd Storage AccuImiIMiulis uI* teed Icsidtics Cl Reduce moisture accumulalion wilhin and
around iIninedinle Ind nictcr or reed storage
nrens by insuring drainage way from site
andlor providing ndcgttnte containnient
covered bin for brewct's grain and similar Itigh
itioisturc grain products),
❑ Inspecl for avid reinove or break tip accumulated
solids in filler strips around feed storage as
Deeded.
A M I C - November I I , 199G, 1'age 1

Sum cc calrse HINII's lu Curl(vol Insecls Site SImcific I'racfices
Anill mI Ifoldill g Aicas Accumulalior►s of.mima! wastes Ci Iil3mina[c low areas llta( Iralt moislurc alairg
amI Feed ►vasl,rgc fences and other localiuns ►vlicre waste
acciinmla[es and dishribancc by animals is
nririintrd.
❑ Ivlainlain-rencc rows and filtcrs[rilrs arotntd
animal holding nI•cas to nlinitni4e
accriiuufalinris or►v:lstcs (i.e., inspect for and
icnrovc or break ill) accumulated solids as
needed).
D1y Mal ill IL: I landIiIIg Accmntih+limis ol•ardiwil musics ❑ Retiiove sl+ill;rge oil a ioil( iiic basis (c.g„ 7 - IU
5ysti:nts cl;+y in[ei vat during StIInnlCr; 15-3[} cl,iy ill tr,i vat
(imint; wiI$lei-) ►vIlei c nrstnill c is Ivadcd for Fault
application ur disllusal.
❑ I'rovidc fill adcquale dIaill "ge "sound nmimic
stockpiles.
Cl Iiispecl [or it remove or bleak nli accmnulalcd
wasics in Filter strips around stuckpilcs mid
Inatimc handling areas as needed,
Fur nnnc iitroltuation cuitlact Ilrc Cuuircrttivc I?xicnsion Scivice, Uclrmlmcrtt oriintciinulogy, Flux 7613, Fluid[ Caiulina State [University,
Ralcigh, NC, 27695-7613.
•
AMIC - Now iitbcr 11, 199G, 1'agc 2

Hubbard Baker
Mortality 1ylarta;ement lethods
(check which methods} are bein z implemented)
Burial three feet beneath the surface of the ground within 24 hours after
knowledge of the death. The burial must be at least 300 feet from arry flowing
J stream or public body of eater. r
u[ Rendering at a rendering plant licensed under G.S. 106-16S.7
u Complete incineration
�l In the case of dead poultry only, placing* in a disposal pit of a size and design -
approved by the Department of A-riculture
Any method which in the professional opinion of the State Veterinarian would
make possible the salvage of part of a dead animal's value without endangering_ _
human or animal health. (Written approval of the State Veterinarian must be
attached)
December 13. 1996

Hubbard Baker Project Name: Baker
Randolph County _ . _ - -- _ _. - _ _ July 16, 1998
Animal Waste Management Plan Certification
(Please type or print all information that does not require a signature)
Existing or New or Expanded (please circle ok ;Existing
General information:
Name of Farm: Baker Farm Facility No: _ 76-10
Dwtxter(s) Flame: - - I Lubbard_�3aker_ - phone No: _ (91 p) 498- 7973
Mailing Address: 3113 Marl oro Chi c Road 5012hie North Carol' "7354
Farm Location: Count} Farm is Located in:_ Randolyh_ _ _ _ __ _ _ __v�
Latitude and Longitude 35 49 - 58 -1 i9 53 29
Please attach a copy of a county road map with location identified and describe below (Be specific, road names, directions,
mileposts, etc.): US 220 North from Asheboro to US 31 l Noqb 5 miles to Marlboro Ch- Road in left one chile to
Baker Farm Road on left zo to end of_driye
Q oration Descri tion:
Type of Swine Na, of Anirnals
_ Wean to Feeder
x Feeder to Finish 1.9
�Farrowv to Wean
Y Farrow to Feeder
~Farrow to Finish
Expanding Operation Only
Previous Design Capacity:
Total Design Capacity:______
Type of Poultry No, of l4wmals
Layer
Pullets
Other type of Liveslock
7:vpe of Carde No. gMntmals
Dairy
Beef
Number ofAwrnals
Additional Design Capacity
Acreage Available for Application: S>5 Required Acreage: 25.3
Number of LagoonslStorage Ponds: 1 Total Capacity: �_ L) I Cubic Feet (fL3)
Are subsurface drains present on the farm: YES o NO (please circle one)
Lf YES: are subsurface drains present in the area oithe GOON or SPRAY YIELD (please circle one)
I (we) verify that aE the above information is correct and will be updated upon changing, I (we) understand nic operation
and maintenance procedures e=bbshad in the approved animal waste managerneut plan for the farmnamed above and
will implement these procedures, i (we) know that any expansion to the existing design capacity of the waste treatment
and storage system or construction of new facilities will require a neu certification to be ,submitted to the Division of
Environmental Management before the new animals are stocked. I (we) understand that there must be no discharge of
animal w=v-from the storage or application system to surface waters of the state either directly through a manmade
conveyance or from a storm event less severe than the 25-year, 24-hour storm and there must not be ran -off from the
application of animal waste. I (we) understand that run-o$ of pollutants from lounging and heavy use areas must be
minimized using technical standards developed by the Natural Resources Conservation Service. The approved plan will
be filed ai the farm and at the office of the local Soil and Water Conservation Service. I (we) know that any modification
must be approved by a technical specialist and submitted to the Soil and Water conservation district prior to
ianplemmiat on, A change in land ownership requires written notification to DEM or a new ccrtif radon ( if the approved
plan is changed) within 60 days of a title transfer.
Name of Land Owner. IVGe��ff&. %1�7 Z2! —J Ar,
Signature: D ate:
Name of -Manager (if different from own r
signature: Date:
6of11
nr
. ......., . �....; ter:. ... -. :.� r,. :-_.... . ..... ....-� ....—..—�__...:-.W:�.:�-•'-^.'.r..

Hubbard Baker Far `T Project Name; Baker
Randol h County Jul►' 16, 1998
Technical Specialist Certification
I. As a technical specialist designated by the North Carolina Sail and Water Conservation Commission pursuant to
15A NCAC 6F .0005, 1 certify that the animal waste management system for the farm named above has an
animal waste management plan that meets or exceeds standards and specification of the Division of
Environmental Management (DENT) as specified in 15A NCAC 2R0217 and the USDA -Natural Resources
Conservation Service (NRSC) and/or the North Carolina Soil and Water Conservation Commission pursuant to
15A NCAC 2H.0217 and 15A NCAC 617.0001-.0005. The following elements are included in the plan as
applicable. while each category designates a technical specialist who may sign each certification (SD, SI, VW.
RC, 1 , the techtcal specialist should orily certify parts for which they are technically competent-
H. Certification of Design
A) Collection. Stora a Treatment Svstem
/r,sioin�facility without retrofit LSD or V_AM
Storage volume is adequate for operation capacity; storage capability consistent with waste utilization
requirements.
New, expanded or retrofitted facilit%, LSD)
Animal waste storage and treatment structures, such as but not ]united to collection systems, lagoons and ponds,
have been designed to meet or exceed the minimum standards and specifications.
Name of Technical Specialist (Please print)
Affiliatiot
Address:
Signature
K)
Land Application Site L]P�
The plan provides for minimum separations (buffers); adequate amount of land for %vaste utilization; chosen crop
is suitable for waste management; hvdraulic and nutrient loading rates.
Name of Technical Specialist (Please print): �> • I�ar4o- RO 1 ?
Affiliation: (k5 bA- - 4 RC S
Address: (Agpr_7): /V(- Z7z v-S
Signature: Date:
C) RunofrControls from Exterior hots
Ch file appropriate box
Facil-n, uithaut ext 'or lots SD or W[iP or RC
This facility' does not contains any exterior lots.
--Facility with exterior lots (RC)
Methods to minimize the run off of pollutants from lounging and heavy use areas have been designed in
accordance with technical standards developed by NRCS.
Name of Technical Specialist (Please print):
Affiliation
Address:
Signatun
7c II
fir. b-1115 071�1

0
Hubbard Baker Fe Project Name: Baker
Randolph Count►_ _ _ ` _ Jul_►' 16, 1998
D) lication and Handling E ui meat
Check the appropriate box
Exist' g or exj2az)dijjg facility ih existing.waste ap2licatLoyLeguipment N7UP r I
Animal waste application equipment specified in the plan has been either field calibrated or evaluated in
accordance with existing design charts and tables and is able to apply waste as necessary to accommodate the
waste management plan: (existing application equipment can cover the area required by the plan at rates not to
exceed either the specified hydraulic or nutrient loading rates, a scbcdule for timing of applications has been
established-, required buffers can be maintained an calibration and adjustment guidance are contained as part of
the plan).
-x_ New, e pq ded gr exists facili_ri without existingwaste application equipment for spray i�rr ration- 1
Animal waste application equipment specified in the plan has been -designed to apply waste as necessary to
accommodate the waste management plau; (proposed application equipment can cover the area required by the
ti•'` �, CARD 'p n at rates not to exceed either the specified hydraulic or nutrient loading rates: a schedule for timing of
;`� p��.•. • �Jc-Acations has been established; required buffers can be maintained; calibration and adjustment guidance are
��,T contested as part of the plan).
1 'Q�
L& -- cr. expanded or existingIacilih' without existing waste application equipment for land spreading not using
:' 022536 . . ... �-.. — - —
r �
-q i�Gl��� •�l waste application equipment specified in the plan has been selected to apply waste as necessary to
y .,_Prq ''••••.... �cbmmodate the waste management plan.; (proposed application equipment can rover the area required by the
+� J G �,"plan at rates not to exceed either the specified hydraulic or nutrient loading rates; a schedule for timing of
jilittOapptions has been established; required bogeys licacan be maintained; calibration and adjustment guidance are
contained as part of the plan).
Name of Technical Specialist (Please print): Brian J. GannM P. F,.
AfUation: North Carolina Department of Environment Heal!L & Natural Resources - Division of Sail �, Water
Address: (Agpipy) _127 LardinO-DrriveExtension, Wilmin tgton. NC 28405-3845 )Phole No.: (91 Qi395-000
Signature:
E)
or
o rta lit►'
Date:
Si.
The waste management plan for this facility includes a Waste management Odor Control Checklist, an insect
Control Checklist, a Mortality Management Checklist and an Emergency Action Plan. Sources of both odors and
insects have been evaluated with respect to this site and Best management Practices to Minimize Odors and Best
Management Practices to Control insects have been selected and included in the waste management plan. both
the Mortality Management Plan and the Emergency Action Plan are complete and can be implemented by the
facility. Name of Technical Specialist (Please print): _ �, 114-11" �'� sb-+ti-
Ainiation: A - 149YS
Address: (A ecncv1: Z_L&_ A-4 , 0 h] G Z 7 7-0 3
Signature
F)
Written Notice orlNew or Exnandinu Swine Farm
The following signature block is only to be used for new or expanding rw ne farms that begin
construction after ,Tune 2I, 1996. If the facility was built before June 21, 1996, when was it constructed or
last expanded
I (we) certify that I (we) have attempted to contact be certified mail all adjoining property owners and all
property owners who own property located across a public road, street, or highway from this new or expanding
swine farm. The notice was in compliance witb the requirernen of NCGS 106-905. a copy of the notice and a
hSt of the property owners notified is attached. /L
Name -of Technical Specialist (Please print); �T
Affiliation: _
Address: (Agency):
Signature:--
(3)
8 of 11

Jl}
Hubbard Baker Fas Project Name: Raker
Randolph Count' ��. _ Jub" 16,1998
III Certif cation of Installation
A) Collection, Storan,^Treatment Installation
ew ex anded or r trofitted facili S
Animal waste storage and treatment structures, such as but not limited to lagoons and ponds, have been installed
in accordance with the approved plan to meet or exce6 the minimum standards and specifications.
For ezistrrrgfacilitaes without retrofits, no certifcatLon is necessary.
Name of Technical Specialist: (Please print)
Address: (Agency) Phone No.:
Signature: Date:
R) Land Application Site_MU_P_ ]
Check ih ro !e box
The cropping system is in place on all land as specified in the anima] waste management plan,
6-rrksa esra6I's fed .s_is--99
Conditional Approval: all required land as specified in the plan is cleared for planting the cropping
system as specified in the waste utilization plan has not bem establis�y34 and the owroer has committed to
establish the vegetation as specified in the plan by L `" Y 7 � (monthldaylyC. the
proposed cover crop is appropriate for compliance with the waste utilization plan.
Also check this box if appropriate
If the cropping system as specified in the plan cannot be established on newly cleared l and within
30 days of this certification, the owner ham committed to establish an interim crop for erosion
con"]] C ' � 3 Z t {
r — ---
Name of Technical Specialist {Please print}: t3i�r'�ri_ �16 pars
A.ffiliatior
Address:
Signature
This foil owing signature block is only to be used when the box for conditional approval in III.$ above has been
checked,
I (eve) certify that I (wc) have committed to establish the cropping system as specified in my (our) waste utilization plan,
and if appropriate to establish the interim crop for emsion control, and will submit to DEM a verification of completion
from a Technical Specialist within 15 calendar days following the date specified in the conditional certification. I (we)
realize that failure to submit this verification is a violation of the waste management plan and will subject me (us) to an
enforcement action from DEA
L-.�a..c�oc�n r•�:
Name of { r lease riot): ,4%'cor
r
Signature: _ Date:
(4)
- 9OfII

r. '�` u, I. [+�• w 33631E36494
MO. 410 t702
C) RlInntr Con ro on = r.tennr Lots (RC)
;v[Lab�xt% to atinimixc trig run off of poIIUMriU CfQn; luuneing xna ea%-v use areas havc been ina4%Ilud as Specified
in the plan..
Forfaciliries wilhour exterior lots, no cer tificarion is necessnr7.
fume of Technical Specialist (Please Print►):
Affiliati
Address (AScnt:y):
att Work Completed:
Phone No.:
Signa[utr: ,. Date:
D) AoRlicatiort and' 14nnddlinZ Equipment Installation (WLT or 1)
Gteck rlte_ap� h.we block..
_„/ Y Animal wasts pplication and nandting equipatznt spccifleJ in .he plan is on site and read• for u:e:
4 czlibration•arnd adjt;scz^M materials have been provided to Uie owners and are contzinet} as part at the plan.
UjE?rA1LLr- ..AtCRSS wru.. NSIM 't4 ZE PEC.AtQULAr_b BY GRkkAc
.J AV.iatiil w'astc application and Nano tir+g eyuipnIcnt spcciFLcd in tflt plan IISLi not bee irt..tsil�:d bvt tht oµ ncr
has propasc lcaslag or third party application and has provi&J a signet; contract. quiprnem specified in
the contC?ct agrCes with We requiremen:s of the plan,; reyvired buffers can be rtuntai:tad: calib.ation and
ad;ustmcan guidvtcZ tta►e be -en pro,'ioed to vic owners and are contained as pa:t of the Plan.
J Conditional: approval: Animal waste application and handling equipmcm specified in tine plait has
been purch sad and will be on site aml installed by {mar thlcUyI'k;r W: there ;5 azicgcatr
storage tD hold the wale until the cyaipnient is inimlled and und'. the wraste can be lanai applitd in
accordance: wiLh the croppiaY systcm contained in t.'te plan; and calibration acne,' adiasuneat euiawice have
been provided to the ownem and are contained as pan of the' pian.
dame of Technical Specialist (Please Ph m) DA J Tn RP H A
Afttliabon - r Date Work Compie:cd:1-2jal4e
�.ddras5 (Agency}; c t� a ntacresc �jc �2 phone No,;��-R9S-3a'�s
Sigrtzture: _._ _` � �. -�-�, -Date - /.-. /x.IR + `
The following sigctature block.is only to be used when the bax for condidcnaI approval in III D
above has been cheGced....
[ (we) cerdfy'tnu 1.(vsi) time commi red to purchase the aid rnal was cc applicadon and handlinE equipler.t
specified in my (our)'v"rste to ' agement plan arse will vutth nit to DEM a ven i:=ion of delivery am: instalizdan
from a. Ttd%nicai Specialist 'v9amn 17 Calendar 03VS rollowin_ tn-^ [laic Speciliea ir, the ctondiSonal certification. I
(wcI realize that failure'to submit thls verif ttaLi0n is a ti,iolation of the waste m:inaeuntn( pi=' aria Will subject rnt
(us) to an eniorccmcru.action tram DE.t.
lame of Land Owner.
Date:
Name of Managerli different from owner):
Signature: Date:
E) Qdar Mtrvl._In5ect Control -and i rrraiity yianagement fSD. SY. Wv ' RC r it
Methods to control odors and insccu as spec tied in the Plan l ave been irlsudled and are upr_r'at:Qnal" The
mortality rnanagemau System as specified in the Plan hag asv beets installed -and is operational.
N asTte of 7erhnical Specialist (Picric Print): � &e4n Eva ey'-� are-
Atfiliadnn czS.[7A N•RWore Complo d•
Address (Agt77
,k`r .. Aufiust I, t9'37.. '
7Zo'j Phone .No: 336 (-,z5-q
Date: 9

Hubbard Baker Fav Project Name: Baker
Randol h Count►, July 16, 1998
Please return the above completed forms (pages 5-9) to the Division of Water Quality at the
following address:
Department of Environment, Health, and Natural Resources
Division of Water Quality
Water Quality Section Compliance Group
P.O. Boa 29535
Raleigh, North Carolina 27626-05035
Please also remember to submit a copy of this form along with the complete Animal Waste
Management Plan to the local Soil & Water Conservation District Office and to keep a copy
in your files with your Animal Waste Management Plan.
II ofII

Wr',iS DESIGN IS FOR A SINGLE STA Av:]ON
CLIENTS NAME _______________»______=_==] HUBBARD BAKER
COUNTY NAME RANDOLPH COUNTY
TODAY'S DATE
w====____________________]
OCT. 17, 1997
DISTANCE TO NEAREST
NONFARM RESIDENCE =7
750+ FEET
NUMBER OF PIGS
WEANLING TO FEEDER
NUMBER OF PIGS
FEEDER TO FINISH =__-__]
1,900
NUMBER OF SOWS
FARROW TO WEAKLING
NUMBER OF SOWS
FARROW TO FEEDER
NUMBER OF SOWS
FARROW TO FINISH
DEGREE OF ODOR
CONTROL
(minimum
1.0 cu. ft. per lb SSLW)
(maximum
3.0 cu. ft. per lb SSLW)
NUMBER OF YEARS
OF SLUDGE ACCUMULATION ]
1 YEARS
TOP LENGTH AT NORMAL WATER LEVEL240.0 FEET
TOP WIDTH AT NORMAL WATER LEVEL =______] 175.0 FEET
NORMAL WATER LEVEL ELEVATION =----=====] 94.4 FEET
SEASONAL HIGH WATER TABLE ELEVATION ==_] 92.0 FEET
LAGOON BOTTOM ELEVATION86.4 FEET
Depth of Permanent Water 8.0 feet
(minimum depth without sludge = 6 feet)
(minimum depth with sludge = 8 feet)
SIDE SLOPES ___________________________] 2.0 :1
Permanent Volume Required 285,228 cubic feet
Permanent Volume Provided 285,621 cubic feet
ADDITIONAL DRAINAGE AREA IN SQUARE FEET] SQUARE FEET
(i.e_. pumpout pond & other outside drainage area)
LENGTH OF
PUMPING CYCLE
180
DAYS
GALLONS OF FRESH WATER ADDED DAILY =___]
GALLONS
EXCESS RAINFALL ABOVE EVAPORATION =____]
9.28
INCHES ---
25YR/24HR
STORM RAINFALL =___---__-____]
6.20
INCHES
FREEBOARD
1.2
FEET
ESTIMATED
TOP OF DAM ELEVATION =______]
98.5
FEET
Temporary
Storage Volume Nee 125,945
cubic feet
Temporary
Storage Volume Pro 128,910
cubic feet
Top of Dam Elevation 98.5 feet
Inside Dimensions of Lagoon at Top of Dam:
Leng 256.4 feet 191.4 feet
ESTIMATED DEPTH TO PUMP _______________] 2.3 FEET
Volume To
Be Pumped =
100,590
cubic feet
Volume for
Est. Depth =
101,056
cubic feet
Begin Pumping
Elevation =
96.7
feet
Stop Pumping
Elevation =
94.4
feet
Page 1

n�5 DESIGN IS FOR A SINGLE STA AvOON
1. STEADY STATE LIVE WEIGHT
0
head
weanling to feeder
x 30 lbs. =
0
lbs
1,900
head
feeder to
finishing
x 135 lbs. =
256,500
lbs
0
sows
farrow to
weanling
x 433 lbs. -
0
lbs
0
sows
farrow to
feeder x
522 lbs. -
0
lbs
0
sows
farrow to
finish x
1417 lbs. =
0
lbs
TOTAL STEADY
STATE LIVE
WEIGHT (SSLW) =
256,500
lbs
2. SLUDGE ACCUMULATION
Sludge accumulates at the rate of 0.080 cu. ft. per year per pound
of STEADY STATE LIVE WEIGHT.
Years of sludge accumulation in design? 1.4
Sludge Volume = SSLW *years of sludge accumulation * 0.08
Sludge Volume = 28,728 cubic feet
3. REQUIRED LIQUID VOLUME OF LAGOON
Design lagoon for 1.0 cu. ft. per pound SSLW
Total Volume = (SSLW * Design factor) + Sludge Volume
Total Volume = 235,228 cubic feet
4. NORMAL LAGOON LIQUID LEVEL
Maintain normal lagoon liquid level at elevation 94.4 feet
Construct lagoon bottom to elevation 86.4 feet
Lagoon size for normal lagoon liquid volume using prismodial formula:
SS/END1 SS/END2 SS/SIDE 1 SS/31DE2 DEPTH
2.D 2.0 2.0 2.0 8.0
AREA OF TOP
LENGTH * WIDTH =
240.0 175.0
AREA OF BOTTOM
Lb Wb -
208.❑ 143.0
42,000 (AREA OF TOP)
29,744 (AREA OF BOTTOM)
AREA OF MIDSECTION
Lm Wm =
224.0 159.0 35,616 (AREA OF MIDSECTION)
CU. YD. = {AREA TOP + (4*AREA MIDSECTION) + AREA BOTTOM) * DEPTH/6
42,000 142,464 29,744 1.3
VOLUME OF LAGOON AT NORMAL LAGOON LIQUID LEVEL = 285,611- CU. FT.
VOLUME NEEDED = 285,228 CU. FT!
Page 2

0,113 DESIGN IS FOR A SINGLE STA Ai,OON
5. DIKE
THE SURFACE DIMENSIONS OF THE LAGOON AT NORMAL LIQUID LEVEL
ARE: 240.0 FEET LONG BY 175.0 FEET WIDE
Place spoil as a continuous dike to elevation
6. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width
256.4 191.4
Additional Drainage A
TOTAL DA =
Pumping cycle to be
49,075 square feet
0 square feet
49,075 square feet
180 days.
98.5 feet.
6A. Volume of waste produced
Volume = 256,500 SSLW * 0.0201482 gallon/lb SSLW/ day * 180
days in the pumping cycle divided by 7.48 gallons per cubic foot.
Volume = 62,639 cubic feet
6B. Volume of wash water
This is the amount of fresh water used for washing floors or volume of
fresh water used for a flush system. Flush systems that recycle the
lagoon water are accounted for in 6A.
Volume = ❑ gallons/day 180 days in the pumping
cycle divided by 7.48 gallons per cubic foot_
Volume = 0 cubic feet
6C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by the largest amount
Excess rainfall (differencey = 9.3 inches
Volume = 9.3 inches * DA / 12 inches per foot.
Volume = 37,951 cubic feet
6D. Volume of 25 year - 24 hour storm
Volume = 6.2 inches * DA / 12 inches per foot.
Volume = 25,355 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
6A. 62,639 cu. ft.
6B. 0 cu. ft.
6c. 37,951 cu. ft.
6D. 25,355 cu. ft.
TOTAL TEMPORARY STORAGE: 225,945 CUBIC FEET
Page 3

} W.IS DESIGN IS FOR A SINGLE STAAA.,OON
7. DEPTH ❑F STORAGE REQUIRED (ABOVE NORMAL LIQUID ELEVATION OF LAGOON)
VOLUME OF TEMPORARY STORAGE WHEN TOP OF DAM IS 98.5 FEET ELEVATION
AREA OF BOTTOM = 42,000 sq. ft.
AREA OF TOP = 46,949 sq. ft.
AREA ❑F MIDSECTION = 44,441 sq. ft.
VOLUME PROVIDE❑ = 128,910 cubic feet
THE INSIDE EDGE DIMENSIONS OF THE DAM AT ELEVATION 98.5 FT.
ARE: 256.4 FEET BY 191.4 FEET.
S. SET BEGIN PUMPING ELEVATION
STORAGE VOLUME TO BE PUMPED
6A.
62,639
cubic feet
6B.
0
cubic feet
6C.
37,951
cubic feet
TOTAL VOLUME
TO BE PUMPED:
100,59❑
cubic feet
VOLUME AT ESTIMATED PUMPING
DEPTH
AREA OF BOTTOM =
42,000
sq. ft.
AREA OF TOP =
45,903
sq. ft.
AREA OF MID -SECTION =
43,930
sq. ft.
VOLUME PROVIDED =
101,056
cubic feet
DESIGNED BY: APPROVED BY:
DATE: DATE:
Page 4