370015_HISTORICAL_20171231

NORTH CAROLINA .�
Department of Environmental Quai

l �y�. �- �

ace©�
North Carolina Department of Environment and Natural Resources
Pat McCrory
Governor
Paul T Lilley
Paul Lilley Farm
146NC37S
Gatesville, NC 27938-9608
Dear Paul T Lilley:
John E. Skvarla, III
Secretary
October 1, 2014
Subject: Certificate of Coverage No. AWS370015
Paul Lilley Farm
Swine Waste Collection, Treatment,
Storage and Application System
Gates County
In accordance with your renewal request, we are hereby forwarding to you this Certificate of Coverage
(COC) issued to Paul T Lilley, authorizing the operation of the subject animal waste management system
in accordance with General Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for Paul Lilley Farm, located in Gates County, with a swine animal capacity of no greater
than the following annual averages:
Wean to Finish: Feeder to Finish: 450 Boar/Stud:
Wean to Feeder: 180 Farrow to Wean: 20 Gilts:
Farrow to Finish: Farrow to Feeder: Other: 70
If this is a Farrow to Wean or Farrow to Feeder operation, there may be one boar for each 15 sows. Where
boars are unnecessary, they may be replaced by an equivalent number of sows. Any of the sows may be
replaced by gilts at a rate of 4 gilts for every 3 sows.
This COC shall be effective from the date of issuance until September 30, 2019, and shall hereby void
Certificate of Coverage Number AWS370015 that was previously issued to this facility. Pursuant to this
COC, you are authorized and required to operate the system in conformity with the conditions and
limitations as specified in the General Permit, the facility's CAWMP, and this COC. An adequate system
for collecting and maintaining the required monitoring data and operational information must be
established for this facility. Any increase in waste production greater than the certified design capacity or
increase in number of animals authorized by this COC (as provided above) will require a modification to
the CAWMP and this COC and must be completed prior to actual increase in either wastewater flow or
number of animals.
Please read this COC and the enclosed State General Permit carefully. Please pay careful attention to the
record keeping and monitoring conditions in this_petmit. Record keeping forms are unchanged with this
General Permit. Please continue to use the same record keeping forms.
1636 Mall Service Center, Raleigh, North Carolina 27699-1636
Phone: 91U07-64641Internet: http://www.nrdenr.aov/
An Equal Opportunity 1 Affirmative Action Employer — Made in part by recycled paper

If your Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inacdurate
you will need to have a new WUP developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (Local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Per NRCS standards a 100-foot separation shall be maintained between water supply wells and any
lagoon, storage pond, or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Program for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition I1.22 of the General Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Tropical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You
may find detailed watch/warning information for your county by calling the Wakefield, VA National
Weather Service office at [phone], or by visiting their website at: htto://www.weather. og v/&q/
This facility is located in a county covered by our Washington Regional Office. The Regional Office staff
may be reached at 252-946-6481. If you need additional information concerning this COC or the General
Permit, please contact the Animal Feeding Operations Program staff at [phone].
Sincerely,
for Thomas A. Reeder
Director, Division of Water Resources
Enclosure (General Permit AWG100000)
cc: (Certificate of Coverage only for all ccs)
Washington Regional Office, Water Quality Regional Operations Section
Gates County Health Department
Gates County Soil and Water Conservation District
WQROS Central Files (Permit No. AWS370015)
AFO Notebooks

NCDENR
North Carolina Department of Environment and Natura
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins
Governor Director
April 20, 2011
Paul Z Lilley
Paul Lilley Farm
146 NC 37 S
Gatesville, NC 27938-9608
Resources
Dee Freeman
Secretary
Subject: Sludge Survey Testing Dates
Certificate of Coverage No. AWS370015
Paul Lilley Farm
Animal Waste Management System
Gates County
Dear Paul T. Lilley:
The Division of Water Quality (Division) received your sludge survey information on April 14,
2011 lagoon #1-Primary at the above referenced facility. With the survey results, you requested
an extension of the sludge survey requirement for this lagoon at the Paul Lilley Farm. Due to the
amount of treatment volume available, the Division agrees that a sludge survey is not needed
until 2013 for the #1-Primary lagoon. Please note that this extension is only valid for the.#1-
Primary lagoon; any other lagoons should have a sludge survey performed on the normal
schedule, before December 31, 2011.
The next sludge survey for the-#1-Primary lagoon at Paul Lilley Farm should be performed
before December 31, 2013. Thank you for your attention to this matter. Please call me at (919)
715-6627 if you have any questions.
Sincerell�y--,--y--��,�
Christine B. Lawson
Animal Feeding Operations Unit
cc: 'Washington Regional Office, Aquifer'Protection Section
Permit File AWS370015
APR 20
1636 riai! Service cenie;. Ralei#, Nortm Carolina 27699-163F One 1
Locabor:2,7_18CaDialBim,kaleiali,lvorriCarolina2760-'� NOI-thCarolliia' '
Pnon. 91.73 -2?, Frix: 9i9_715-05U. I I.muncr Service 'I-Eli-62:1-674s.
mime;. SvwJr.ticwate'nuaGrv.ar�; d ► i'i 6 `7
4I LGiW!'J,".'.'^'IFIl frliativ9;1v nri i'.ftlrll+lvi

sr�
��p
H` CDEN�
North Carolina Department of Environment and Natural Resources
Beverly Eaves Perdue
Governor
Paul T Lilley
Paul Lilley Farm
146 NC 37 S
Gatesville, NC 279389608
Dear Paul T Lilley:
Division of Water Quality
Coleen H. Sullins
Director
October 1, 2009
Dee Freeman
Secretary
Subject: Certificate of Coverage No. AWS370015
Paul Lilley Farm
Swine Waste Collection, Treatment,
Storage and Application System
Gates County rrl 6"lth..a.
In accordance with your renewal request, we are hereby forwarding to you this Certificate of Coverage
(COC) issued to Paul T Lilley, authorizing the operation of the subject animal waste management system
in accordance with General Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for the Paul Lilley Farm, located in Gates County, with a swine animal capacity of no
greater than the following annual averages. -
Wean to Finish: Feeder to Finish: 450 Boar/Stud:
Wean to Feeder: 180' Farrow to Wean: 20 Gilts:
Farrow to Finish: Farrow to Feeder: Other: 70
If this is a Farrow to Wean or Farrow to Feeder operation, there may be one boar for each 15 sows. Where
boars are unnecessary, they may be replaced by an equivalent number of sows. Any of the sows may be
replaced by gilts at a rate of 4 gilts for every 3 sows.
The COC shall be effective from the date of issuance until September 30, 2014, and shall hereby void
Certificate of Coverage Number AWS370015 that was previously issued to this facility. Pursuant to this
COC, you are authorized and required to operate the system in conformity with the conditions and
limitations as specified in the General Permit, the facility's CAWMP, and this COC. An adequate system
for collecting and maintaining the required monitoring data and operational information must be
established for this facility. Any increase in waste production greater than the certified design capacity or
increase in number of animals authorized by this COC (as provided above) will require a modification to
the CAWMP and this COC and must be completed prior to actual increase in either wastewater,flow,.—ofL,:."-..
number of animals. w:
General Permit. Please continue to use the same record keening forms.
1636 Mail Service Center, Raleigh, North Carok6na 27699.1636
Location: 2728 Capital Blvd., Raleigh, North Carolina 27604
Phone: [phone] FAX: [phone] Customer Service: 1-877-623-6749
Internet: www.ncwaterquality.org
An Equal Opportunity 1 Affirmative Action EmQioyer
)av careful attention OAhe-',
slave -unchanged -with -this
l
N OCT 2 0 2009 .
�hrrgi�'NCarolina �i`i ina
Alaninally

If your Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Per 15A NCAC 2T .0105(h) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100-foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, then an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Unit for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition II.22 of the General Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Ttopical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You
may find detailed watch/warning information for your county by calling the Wakefield, VA National
Weather Service office at [phone], or by visiting their website at: www.erh.noaa.gov/er/akg/
This facility is located in a county covered by our Washington Regional Office. The Regional Office
Aquifer Protection Staff may be reached at [phone]. If you need additional information
concerning this COC or the General Permit, please contact the Animal Feeding Operations Unit staff at
[phone].
Sincerely,
for Coleen H. Sullins
Enclosure (General Permit AWG100000)
cc: (Certificate of Coverage only for all ccs)
Washington Regional Office, Aquifer Protection Section
Gates County Health Department
Gates County Soil and Water Conservation District
APS. Central Files (Permit No. AWS370015)
AFO Notebooks

Producer:
Location:
Address:
Telephone:
Type of Operation:
Number of Animal Units:
Paul Lilley
NC 37 1 Mile of Gatesville, NC
146 NC 37 South
Gatesville, NC 27938
252-357-2575
Swine
Wean to Feeder -- 180
Feeder to Finish -- 450
Farrow to Wean - 20
The waste from your animal facility must be land -applied at a specified rate to prevent pollution of surface
and/or ground water. The plant nutrients in the animal waste should be used to reduce the amount of
commerical fertilizer required for the crops on the fields where the waste is to be applied. This waste utilization
plan uses nitrogen as the limiting nutrient_ Waste should be analyzed before each application cycle and annual
soil tests are strongly encouraged so that all plant nutrients can be balanced for realistic yields of the crops to be
grown.
Several factors are important in implementing your waste utilization plan in order to maximize the fertilizer
value of the waste and to ensure that it is applied in an environmentally safe manner. Always apply waste based
on the needs of the crop to be grown and the nutrient content of the waste. Do not apply more nitrogen than the
crop can utilize. Soil types are important as they have different infiltration rates, leaching potentials, cation
exchange capacities, and available water holding capacities. Normally, waste shall not be applied to land
eroding at greater than 5 tons per acre per year. With special precautions, waste may be applied to land eroding
at up to 10 tons per year. Do not apply waste on saturated soils or on land when the surface is frozen. Either of
these conditions may result in runoff to surface waters, which is not allowed under DEM regulations. Wind
conditions should also be considered to avoid drift and downwind odor problems. To maximize the value of
nutrients for crop production and to reduce the potential for pollution, the waste should be applied to a growing
crop or not more than 30 days prior to planting. Injecting the waste or disking will conserve nutrients and
reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content for this type of
facility. Actual acreage requirements may be more or less and should be based on the waste analysis report
from your waste management facility. You will, find information on proper sampling techniques, preparation.
and transfer of waste samples to the lab for analysis'in your Certified Operators manual.
This waste utilization plan, if carried out, meet the�.requ fen�ents for, col Nance with 15A NCAC 2H.0217
adopted b the Environmental Management Co !!� '� ' I ��`�' I�
p y g mm}ssion--�-----�..__
i v
�cc AR 2 4 ZOW

t.,
d jIZ i�x iisJ i k .
Amount of Waste Produced per Year
20 sow farrow to wean X 3203 = 64,060 gal.
180 pig wean to feeder X 191 = 34,380 gal.
450 hog feeder to finish X 927 = 417,150 gal.
Total gal. 515,590 gal.
Amount of Nitrogen (N) Produced per Year
20 sow farrow to wean X 5.4 = 108 lbs.
180 pig wean to feeder X 0.48 = 86 lbs.
450 hog feeder to finish X 2_3 = 1,035 lbs.
Total lbs. 12291bs.
Applying the above amount of waste is a big job. You should plan time and have appropriate equipment to
apply the waste in a timely manner.
See attached map(s) showing the fields to be used for the utilization of animal waste. The following acreage
will be needed for waste application based on the crop to grown and method of application;
2

Table 1: Acres Owned by Producer
Tract
No.
Field
No.
Soil
Type
. Crop
Realistic
Yield/Acre
Lbs./N
Per Acre
Acres
Lbs./N
Utilized
Month of
Application
92
1
RoA
Fescue
2.5 Tons
125
6.8
850
Feb. — Oct.
92
2
RoA
Corn
120 bushel
150
6.1
930
Mar. -- .Idly
92
4
AtA
Corn
130 bushel
163
4.4
717
Mar. —July
92
5
ToA
Corn
130 bushel
163
13.5
2200
Mar. -- July
92
7
AtA
Corn
130 bushel
163
4.0
652
Mar. -- .Iuly
92
8
AtA
Corn
130 bushel
163
3.0
489
Mar. -- July
TOTALS
37.9
5838
OR
Tract
No.
Field
No.
Soil
Type
Crop
Realistic
Yield/Acre
Lbs./N
Per Acre
Acres
Lbs./N
Utilized
Month of
Application
92
1
RoA
Fescue
2.5 tons
125
6.8
850
Feb. — Oct.
92
4
AtA
Cotton
850 lbs.
102
4.4
449
May — Judy
92
—4
AtA
Wheat
50
4.4
220
Oct. — Mar.
92
7
AtA
Cotton
850 lbs.
102
4.0
408
May -- July_
92
—7
AtA
Wheat
50
4.0 200
3.0 _ 3U6
Oct. Nliv-
May July
92
8
AtA
Cotton
850 lbs.
102
92
—8
AtA
Wheat
50
3.0
150
Oct. — Mar.
TOTALS
18.2
2583
OR
Tract
No.
Field
No.
Soil
Type
Crop
Realistic
Yield/Acre
Lbs./N
Per Acre
Acres
Lbs./N
Utilized
Month of
Application__
92
1
RoA
Fescue
2.5 tons
125
6.8
850
Feb. — Oct.
92
2
Roh.
Wheat
55 bushel
132
6.2
818
Nov. -- Mar.
92
2
RoA
Soybeans
44 bushel
88
6.2
546
May -- Aug.
92
4
AtA_
Wheat
60 bushel
144
4.4
634
Nov. — Mar.
92
4
AtA
Soybeans
45 bushel
90
4.4
396
May — Aug.
92
5
ToA
Wheat
60 bushel
140
13.5
1 1890
Nov. — Mar.
92
5
ToA
Soybeans
45 bushel
90
13.5
1215
May -- Aug.
92
7
AtA
Wheat
60 bushel
144
4.0
576
Nov. — Mar.
92
7
AtA
Soybeans
45 bushel
90
4.0
360
May — Aug.
92
8
AtA.
Wheat
60 bushel
144
3.0
432
Nov. -- Mar.
92
8
AtA,.
Soybeans
45 bushel
90
3.0
270
May
TOTALS
37.9
7987

OR
If Crop Rotation Follows Soybeans Use This Table
Tract
No.
Field
No.
Soil
Type
Crop
Realistic
Yield/Acre
Lbs./N
Per Acre
Acres
Lbs./N
Utilized
Month of
Application
92
1
RoA
Fescue
2.5 Tons
125
6.8
850
Feb. — Oct. i
92
2
RoA
Com
120 bushel
130
6.2
806
Mar. — Jul.y
92
4
AtA
Corn
130 bushel
143
4.4
629
Mar. — July
92
5
ToA
Corn
130 bushel
143
13.5
1931
Mar. — July
92
7
AtA
Corn
130 bushel
143
4.0
572
Mar. — July
92
8
AtA
Corn
130 bushel
143
3.0
429
Mar. - July
• TOTALS
37.9
5217
OR
Tract
No.
Field
No.
Soil
Type
Crop
Realistic
Yield/Acre
Lbs./N
Per Acre
Acres
Lbs./N
Utilized
Month of
Application
92
1
RoA
Fescue
2.5 tons
125
6.8
850
Feb. —Oct.
92
4
AtA
Cotton
850 lbs.
82
4.4
361
May — Juiy
92
—4
AtA
Wheat
50
4.4
220
Oct. — Mar.
92
7
AtA
Cotton
850 lbs.
82
4.0
328
May — July
92
—7
AtA
Wheat
50
4.0
200
Oct. — Mar.
92
8
AtA
Cotton
850 lbs.
82
3.0
246
May — July
92
—8
AtA
Wheat
50
3.0
150
Oct. — Mar.
TOTALS
18.2
2355
1/ This N is from animal waste only. If nutrients from other sources such as commerical fertilizer are
applied, they must be accounted for. Total N must be based on realistic crop yield expectation.
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N requirements.
Beginning in 1996 the Coastal Zone Management Act will require farmers in some eastern
counties of North Carolina to have a nutrient management plan that addresses all nutrients. This
waste utilization plan only addresses nitrogen.
2/ (—) = Overseoded
4

Table 2: Application of Waste by Irrigation
Tract
No.
Field
No.
Soil
Type
Crop
Application
Rate (In.IHr.)
Application
Amount (In.)
92
1
RoA
Fescue
0.35
0.5
92
2
RoA
Corn
0.35
0.5
92
2
RoA
Wheat
0.35
0.5
92
2
RoA
Soybeans
0.35
0.5
92
5
ToA
Corn
0.35
0.5
92
5
ToA
Wheat
0.35
0.5
92
5
ToA
Soybeans
0.35
0.5
92
4,7,8
AtA
Corn
0.5
0.5
92
4,7,8
AtA
Cotton
0.5
0.5
92
4,7,8
AtA
Wheat
0.5
0.5
92
4,7,8
AtA
Soybeans
0.5
0.5

WASTE DISPOSAL SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade conveyances, direct
application, or direct discharge during operation or land application. Any discharge of waste, which
reaches water, is prohibited.
2. There must be documentation in the design folder that the producer either owns or has an agreement for
use of adequate land on which to properly apply the waste. If the producer does not own adequate land
to properly dispose of waste, he/she shall provide a copy of an agreement with a landowner that is
within a reasonable proximity, allowing him/her the use of the land for waste applicatiui►. It is tlic
responsibility of the owner of the facility to secure an update of the Waste Management Plan when there
is a change in the operation, increase in the number of animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for realistic crop yields -based
on soil type, available moisture, historical data, climatic conditions, and level of management, unless
there are regulations that restrict the rate of application for other nutrients.
4. Animal waste shall be applied on land eroding less than 5 tons per acre per year. Waste may be applied
to land that is eroding at 5 or more tons but less than 10 tons per acre per year providing grass filter
strips are installed where runoff leaves the field.. (See FOTG, Standard 393 -- Filter Strip)
5. Injecting the waste or disking after waste application can reduce odors. Waste should not be applied
when there is danger of driftfrom the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated on
conventionally tilled cropland. When applied to conservation -tilled crops or grassland, the waste may
be broadcast provided the application does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina " for guidance.)
7. *Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff does not
occur offsite or to surface waters and in a method, which does not cause drift from the site during
application. No ponding should occur in order to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that the crop is not covered
with waste to depth that would prohibit growth. The potential for salt damage from animal waste should
also be considered.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a high
potential for leaching. Waste nutrient loading rates on these soils should be held to a minimum and a
suitable winter cover crop planted to take up released nutrients. Waste shall not be applied more than 30
days prior to planting of the crop or forages breaking dormancy.
50

M
WASTE DISPOSAL SPECIFICATIONS
11. Animal waste (other than swine waste from facilities sited on or after October 1, 1995) shall not be
applied closer than 25 feet to perennial waters. (See Standard 393 — Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those owned by the
landowner.
14. Waste shall be applied in a manner not to reach other property and public right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands by a discharge or
by over -spraying. Animal waste may be applied to prior converted cropland provided a "Technical
Specialist' has approved them as a land application site. Animal waste shall not be applied on grassed
waterways that discharges directly into water courses, and on other grassed waterways, waste shall be
applied at agronomic rates in a manner that causes no runoff or drift from the site.
16. *Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall not be
discharged into the animal waste management system.
17. •A protective cover of appropriate vegetation will be established on all disturbed areas (lagoon
embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to protect the vegetation.
Vegetation such as trees, shrubs, and other .woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible. Berms and structures should be
inspected regularly for evidence of erosion, leakage, or discharge.
18. •If animal production at the facility' is to be suspended or terminated, the owner is responsible for
obtaining and implementing a "closure plan" which will eliminate the possibility of an illegal discharge,
pollution and erosion.
19. *Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular basis to prevent
breakdowns, leaks, and spills. A regular maintenance checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops for direct human
consumption. However, if animal waste is used on crops for direct human consumption it should only
be applied preplant with no further applications of animal waste during the crop season.
21. *Highly visible markers shall be installed to mark the top and bottom elevations of (lie temporary
storage (pumping volume) of all waste treatment lagoons. Pumping shall be managed to mallualn the
liquid level between the markers. A marker will be required to mark the maximum storage volume for
waste storage ponds.
7

WASTE DISPOSAL SPECIFICATIONS
22, Waste shall be tested within 60 days of utilization and soil shall be tested at least annually at crop sites
where waste products are applied. Nitrogen shall be the rate — determining element. Zinc and copper
levels in the soils shall be monitored and alternative crop sites shall be used when these metals approach
excessive levels. Phosphorus shall be adjusted for optimum crop production and maintained. Soil and
waste analysis records shall be kept for five years. Poultry dry waste application records shall be
maintained for three (3) years. Waste application records for all other waste shall be maintained for five
(5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina regulations.
• Liquid Systems
9

Your facility is designed for 120 days of temporary storage and should have the temporary storage removed on
the average every 4 months. In no instance should the volume of waste being stored in your structure exceed
elevatioin 50.6.
Call the Natural Resources Conservation Service or Gates Soil and Water Conservation District office after you
receive the waste analysis report to obtain assistance in determining the: amount per acre to apply and the
application rate prior to applying the waste.
Note: Sludge disposal is an item that will need to be addressed every 5-7 years. Your facility will
provide approximately 562 pounds of plant available nitrogen (PAN) per year in the sludge. If
you remove the sludge every 5 years, you will have approximately 2810 pounds of PAN to
utilize. If you apply the sludge to corn at the rate of 125 pounds of nitrogen per acre, you will
need 22.5 acres of land. Please be aware these are only estimates of the PAN and acres needed.
Actual application rates will be based on a waste analysis of the sludge after the sludge has been
agitated, and the realistic yield expectations (RYE) of the host crop.
Narrative of Operation: This Waste Utilization Plan (WUP) has been amended to reflect the crop rotations
used by this operation. Table I shows the receiving crops and computations. This will allow the producer more
flexibility in managing the wastes produced, and provide an opportunity for crop rotations. The acreage shown
in Table 1 represent the minimum wetted acres needed for each crop. Field 1 is fescue pasture and is being
grazed. The wheat/soybean rotation will be a double crop with the wheat being harvested. The soybean RYE
has been reduced to allow for application on the wheat. Any crop rotation. following soybeans will have the
pounds of Nitrogen (N) reduced by 20 pounds to account for the N residue from the soybeans. When the cotton
rotation is used, wheat will be overseeded (—) to allow a fall application. The wheat will not be harvested and
the pouffids N per acre has been reduced to reflect this. These rotations or combination of rotations along with
the fescue pasture will allow full use of the N produced (1229 pounds) by this operation per year. A traveling
gun irrigation system is used for waste application.
Note: This WUP was amended this date per request of Division of Water Quality (J. R. Joshi) to reflect DWQ
clhanges for General Permit.

Waste Utilization Plan Agreement
I (we) understand, will implement and follow the specifications and the operation and maintenance procedures
established in the approver] animal waste utilization plan for the farm named above. I (we) know that any
expansion to the existing design capacity of the waste treatment and/or storage system or construction of new
facilities will require a new utilization plan and as new certification to be submitted to DWQ before the new
animals are stocked. I (we) also understand that there must be no discharge of animal waste from this system to
surface waters of the state for any reason except storm events as severe as the 25-year, 24-hour storm or greater.
The DWQ regulations require a copy of the approved plan be filed on site at the farm office and at the local Soil
and Water Conservation District and will be available for review by DWQ upon request. Failure to comply
with the waste utilization plan will automaticalkrNuire any cost share funds to be refunded to their source.
Name of Facility Owner (Pl:,ase Print): , /a / Z.
liE
Signature:
Name of Manager (If Different from Owner):
Signature:
Date:
Date:
Where owners of animal operations do not have adequate amounts of land to apply the waste, the producer must
pfovide a written agreement, whereby another landowner has agreed to land apply or allow land application on
his or her land. The attached agreement may be used or some other documentation may be provided.
Adjacent Landowner Agreement
I, understand that Mr./Mrs. does not have ample
land to apply the animal waste produced from his/her animal operation. I agree and give permission for
Mr./Mrs. to apply animal waste from his waste system on acres of
my land for the duration of time shown below.
I further understand that th s waste contains nitrogen, phosphorous, potassium, and other nutrient elements and
when properly applied sho-jld not harm my land or crops. I also understand that the use of this waste will
reduce my need for commerical fertilizer.
Term of Agreement:
to
(Minimum of ten years on cost shared items)
(See specification No. 2)
Recipient Landowner (Please Print):
Signature
Date:
HIC

Plan Approval
Name of Technicat Specialist (Please Print): A1.4 f'`a11cy''d /,01eiln l
Affiliation (Agency):
Address:
Signature!�,��y„�,�, f oate: G ZS QZ�
SWCD Board Review
SWCD Represents-tive (Please Print):
Signature: �� Date:
I

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Coleen H. Sullins Director
Division of Water Quality
March 28, 2008
Paul Lilley
Paul Lilley Farm
146 NC 37 South
Gatesville, NC 27938
Subject. Sludge Survey Testing Dates
Certificate of Coverage No. AWS370005
Paul Lilley Farm
Animal Waste Management System
Gates County
Dear Paul Lilley:
The Division of Water Quality (Division) received your sludge survey information on September
9, 2008. With the survey results, you requested an extension of the sludge survey requirement
for the primary lagoon at the Paul Lilley Farm facility not to be required until 2009. Due to the
amounts of treatment volume available, the Division agrees that a sludge survey is not needed
until 2009. The results of the 2009 sludge survey are to be submitted by March 1, 2010.
Thank you for your attention to this matter. If you have any questions, please call me at (919)
715-6937.
Sincerely,
714-�
Miressa D. Garoma
Soil Scientist
cc: Washington Regional Office, Aquifer Protection Section
Central Files
Aquifer Protection Section 1636 Mail Service Center
Intemet: www.ncwater ualit - rg location: 2728 Capital Boulevard
An Equal 4pportunitylAffirmadve Aclion Employer— 50% Recycled110% Post Consumer Paper
�r �]i
U
FSEP 2 3
' L C'1FACE
Raleigh, NC 27699-1636 Telephone: [phone]
Raleigh, NC 27604 Fax I : [phone]
Fax 2: [phone]
Customer Service: [phone]

f �0F \NArF94
,OA G
r
❑ 'C
Paul Lilley
Paul Lilley Farm
146 NC 37 South
Gatesville, NC 27938
i.
Dear Paul Lilley:
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
March 18, 2005
{
MAR 18 2005
.I
Subject
.i
Alan W. Klimek, P.E. Director
Division of Water Quality
Certificate of Coverage No. AWS370015
Paul Lilley Farm
Swine Waste Collection, Treatment,
Storage and Application System
Gates County
In accordance with your permit renewal request received on December 1, 2004, we are hereby forwarding
to you this Certificate of Coverage (COC) issued to Paul Lilley, authorizing the operation of the subject
animal waste collection, treatment, storage and land application system in accordance with General
Permit AWG 100000,
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Paul Lilley Farm, located in Gates County, with an animal capacity of no greater
than an annual average of 180 Wean to Feeder, 450 Feeder to Finish, 20 Farrow to Wean, and 70
sows on ground lots and the application to land as specified in the facility's Certified Animal Waste
Management Plan (CAWMP). If this is a Farrow to Wean or Farrow to Feeder operation, there may also
be one boar for each 15 sows. Where boars are unneccessary, they may be replaced by an equivalent
number of sows. Any of the sows may be replaced by gilts at a rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009, and shall hereby void
Certificate of Coverage Number AW3700150166 dated September 24, 2003, and shall be subject to the
conditions and limitations as specified therein.. Pursuant to this COC, you are authorized and required to
operate the system in conformity with the conditions and limitations as specified in the General Permit,
the facility's CAWMP, and this COC. An adequate system for collecting and maintaining the required
monitoring data and operational information must be established for this facility. Any increase in waste
production greater than the certified design capacity or increase in number of animals authorized by this
COC (as provided above) will require a modification to the CAWMP and this COC and must be
completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Since this is a revised State
General Permit, it contains new requirements in addition to most of the conditions contained in the
previous State General Permit. Enclosed for your convenience is a package containing the new and
revised forms used for record keeping and reporting. Please pay careful attention to the record keepine
and monitoring conditions in this permit.
If your Waste Utilization Plan has been developed based on site -specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization PIan developed.
Aquifer Protection Section 1636 Mail Service Center Raleigh, NC 27699-1636
Internet. http://h2o.enr.state.nc.us 2728 Capital Boulevard Raleigh, NC 27604
An Equal OpportunitylAffirmative Action Employer— 50% Recycled110% Post Consumer Paper
tw6fCarolina
a!!y
Phone [phone] Customer Service
Fax [phone].623-6748
Fax [phone]

The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 2H .0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100 foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Washington Regional Office. The Regional Office
Aquifer Protection Staff may be reached at [phone]. If you need additional information
concerning this COC or the General Permit, please contact J R Joshi at [phone].
Sincerely,
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
Washington: Regional- ffice,--Aquifer-Protectian:Section
Gates County Health Department
Gates County Soil and Water Conservation District
APS Central Files Permit File AWS370015
AFO Files

�OF W A TF9Q Michael F. Easley, Governor
William G. Ross Jr., Secretary
{rj North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E. Director
Division of Water Quality
October 28, 2004
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Paul Lilley
Paul Lilley Farm
146 NC 37 South
Gatesville NC 27938
Subject: Application for Renewal of Coverage under the State Non -Discharge General Permit
Dear Permittee:
Your facility is currently approved for operation under one of the Animal Waste Operation General Permits.
These permits expired on October 1, 2004. On June 11, 2004, the North Carolina Division of Water Quality
(Division) issued revised State General Permits for animal facilities. The General Permits were issued in
accordance with the directive of Senate Bill 733 (Session Law 2003-28). The Division staff is currently in the
process of issuing Certificates of Coverage for these revised general permits.
In order to assure your continued coverage under the general permit, you must apply to the Division for renewal.
Enclosed you will find a Permit Coverage Renewal Application Form_ . The application form must be completed
and returned within 60 days from receipt of this letter.
Failure to request renewal of your coverage under a general permit within the time period specified may result in
a civil penalty. Operation of your facility without coverage under a valid general permit would constitute a
violation of NCGS 143-215.1 and could result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the general permits, the enclosed application, or any related matter please feel
free to contact J.R. Joshi at [phone].
Enclosures (COC Renewal Form)
Cc- Gates Soil and Water Conservation District
Washington Regional Office, Division of Water Quality
Permit File AWS370015
Sincerely,
M. Paul Sherman, P.E.
NOV 3 2004 l
1
Nne
r hCaro ina
aturahllf
Aquifer Protection Section 1636 Mail Service Center Raleigh, NC 27699-1636 Phone [phone] Customer Service
Internet: http://h2o,enr.state.nc.us 2728 Capital Boulevard Raleigh, NC 27604 Fax [phone]
Fax [phone]
An Equal Opportunity/Affirmative Action Employer-50% Recycled/10% Post Consumer Paper

! `- to
F W A r - Michael F. Easley, Governor
William G. Ross Jr., Secretary
0 North Carolina Department of Environment and Natural Resources
j Alan W. Klimek, P. E., Director
Division of Water Quality
September 24, 2003
Paul Lilley
Paul Lilley Farm OCT - 12003
146 NC 37 South
Gatesville NC 27938 ®WQ-W,AR®
Subject: Certificate of Coverage No. AWS370015
Paul Lilley Farm
Swine Waste Collection, Treatment,
Storage and Application System
Gates County
Dear Mr. Lilley:
In accordance with your application received on .December 12, 2000 and in accordance with the directive
of Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to Paul
Lilley, authorizing the operation of the subject animal waste collection, treatment, storage and land
application system in accordance with General Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Paul Lilley Farm, located in Gates County, with an animal capacity of no_T W
greater than an annual average of 180 Wean to Feeder, 450 Feeder to Finish, 20 Farrow to Wean, 70
sows on ground lots and the application to land as specified in the facility's Certified Animal Waste
Management Plan (CAWMP). If this is a Farrow to Wean or Farrow to Feeder operation, there may also
be one boar for each 15 sows. Where boars are unneccessary, they may be replaced by an equivalent
number of sows. Any of the sows may be replaced by gilts at a rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until October 1, 2004. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Pernuttee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per NRCS standards a 100 foot separation shall be maintained between water supply wells and any
lagoon or any wetted area of a spray field.
Non -Discharge Permitting Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
Customer Service Center
An Equal Opportunity Action Employer
Internet http://h2o.enr.state.nc,us/ndpu
Telephone [phone] Fax [phone]
Telephone [phone]
50% recycled110% post -consumer paper

Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143,215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
�,�1`i'� ; L it �
This COC is not Automatically, transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
,
If any parts, requirements,' or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Washington Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Michelle McKay at [phone] ext. 544.
Sincerely,
for Alan W. Klimek, F.E.
Enclo`suies (General"Pernvt AWG100000)-��"-----
cc: (Certificate of Coverage only for all cc's)
Washington Regional Office, Water Quality Section
Gates County Health Department _ V
Gates County Soil and Water Conservation District
Permit File AWS37001.5
NDPU Files

r•
Animal Waste Management Plan Certification
I (Please type or 2rint all information that does not require a si"nature)
FxistinL, or New or Expanded (please circle one)
General Information:
Name of Farm:w Paul Lilley Farm _ __ Facility No: 31 -- 15
Owner(s) Name: Paul Lilley _ _ Phone No: 252-357-2575
Mailing Address: 147 NC 37 South, Gatesville, NC 27938
Farnt Location: Hwy 37 1 mile N. of County Farm is located in:' Gates
Galesville
Latitude and Loncitude: 36 25 00 / _Z6_ __4L __QQ Integrator: VA
Please attach a copy of a county road map with location identified and describe below (Be specific: road
names, directions, milepost, etc.): West side of NC 37, 1 mile North of Gatesville
Operation Description:
Type of Swine
Nat. $Animals
Type of Poultry No. of Animals
Type of Dairy No. of Animals
Ti Wean to Feeder
D Layer
❑ Milking
IL Feeder to Finish
450
Q Non -Layer
❑ Dry
71 Farrow to Wean
20
Type of Beef No. of Anintals
Q Heifers
• Farrow to Feeder
a Brood
O Calves
• Farrow to Finish
❑ Feeders
• Gilts
❑ Stockers
O Boars
Other Type of Livestock: SWine
—grotind
SOW Number of Airinrals: 70
OF for rotation to houses
Expanding Operation Only
Previous Design Capacin,:
Additional Design Capacity•:
Total Desien Capacity:
Acreage Available for Application
50.4
Required Acreage
Number of Lagoons / Storage Ponds: 2 Total Capacity: 133, 619 ^Cubic Feet {ft3)
Are subsurface drains present on the farm: YES or �D (please circle one)
If YES: are subsurface drains present in the area of the LAGOON or SPRAY FIELD (please circle one)
Owner / Manager Agreement
I (we) verify that all the above information is correct and will be updated upon changing. I (we) understand the operation and
maintenance procedures established in the approved animal waste management plan for the farm named above and will
implement these procedures..I (we) know that any expansion to the existing design capacity of the waste treatment and storage
system or construction of new facilities will require a new certification to be submitted to the Division of Water Quality
(DWQ) before the new animals are stocked. I (we) understand that there must be no discharge of animal waste from the
storage or application system to surface waters of the state either directly through a man-made conveyance or from a storm
event less severe than the 2-5-year,24-hour storm and there must not be run-off from the application of animal wastc. I (we)
understand that run -oft of pollutants from lounging and heavy use areas must be minimized using technical standards
developed by the USDA -Natural Resources Conservation Service (NRCS). The approved -plan will be filed at the farm and at
the office of the local Soil and Water Conservation District. I (we) know that any modification. must be approved by a
technical specialist and submitted to the Soil and Water Conservation District prior to implementation. A change in land
ownership requires written notification to DWQ or a new certification (if the approved plan is changed) within 60 days of a
title transfer. _-�.----- - --------------
Name of Land Ow ie a u > L ; 0 LffYC, i ��Ii i ER nt�Al_rT'4` SITGTION
Signature:
Name of Nfanaaer (if different frc�r Iuwner):
Date:
S­ U� t
JUL 9 2002
Signature: Date:
AIWC -- December w. 2000 1 1401-DISCHARGE PEHr[ ,ITTENG

r
t
Technical Specialist Certification
I, As a technical specialist designated by the North Carolina Soil and Water Conservation Commission pursuant to 15A
NCAC 6F .0005, 1 certify that the animal waste management system for the farm named above has an animal waste
management plan that meets or exceeds standards and specifications of the Division of Water Quality as specified in 15A
NCAC 2H.0217 and the USDA -Natural Resources Conservation Service andlor the North Carolina Soil and Water
Conservation Commission pursuant to 15A NCAC 2H.0217 and 15A NCAC 6F .0001-.0005. The following elements are
included in the plan as applicable. W-hile each category designates a technical specialist who may sign each certification (SD,
SI, WUP, RC, I), the technical specialist should only certify parts for which they are technically competent.
I.I. Certification of Design
A) Collection, Storage, Treatment:S:ystem
Check the appropriate box
❑ Existing facility without. retrofit (SD or WUP)
Storage volume is adequate for operation capacity; storage capability consistent with waste utilization requirements. .
94 New, expanded or retrofitted facility (SD)
Animal waste' -storage and treatment structures, such as but not limited to collection systems, lagoons and ponds,
have been designed to meet or exceed the minimum standards and specifications.
Name of Technical Specialist (Please Print): Mark F. Pollard
Affiliation USDA, NRCS Date Work Completed: 10-20-97
Address (Agency):
Signature:
4
Phone No.: 252-357-0290 ext .3
Date:
B) Land Application Site (WUP)
The plan provides for minimum separations (buffers); adequate amount of land for waste utilization; chosen crop is
suitable for waste management, hydraulic and nutrient loading rates.
Name of Technical Specialist (Please Print): Mark F. Pollard
Affiliation USDA, NRCS Date Work Completed: 5-2-96
Address (Agency). PO Box 61, Gatesville NC 27938 Phone No.: 252-357-0290 ext.3
Signature: y �r� cam- _.. _ _ _ _ Date: � G�
C) Runoff Controls from Exterior Lots
Check the appropriate box
❑ Facility without exterior lots (SD or WUP or RC)
This facility does not contain any exterior lots.
X3 Facility with exterior lots (RC)
Methods to minimize the tan off of pollutants from lounging and heavy use areas have been designed in
accordance with technical standards developed by MRCS.
Name of Technical Specialist (Please Print): Dennis E. litt_
Affiliation Gate
Address (Agency
Signature:,_
s
SWCD Date Work Completed:12-30-97
PO Box 61, G�a..t/.esville, NC 27938 Phone No.:252-357-0290 ext.
3
ANVC -- December S, 3otlt)

III. eertif cation of Installation
A) Collection. Storage, Treatment Installation
New, expanded or retrofitted facility (SI)
Animal waste storage and treatment structures, such as but not limited to lagoons and ponds, have been installed in
accordance with the approved plan to meet or exceed the minimum standards and specifications,
For existing facilities without retrofits, no certification is necessary.
Name of Technical Specialist (Please Print): Mark F. Pollard
Affiliation USDA, NRCS Date Work Completed: 10-20-97
Address (Agency): PO Box 61 Gatesville NC 27938 Phone No.: 252-357-0290 ext
Signature: - __ Date: .5 C
B) Land Application Site (WUP)
The cropping system is in place on all land as specified in the animal waste management plan.
Name of Technical Specialist (Please Print): Dennis E. Utt
3
Affiliation Gates SWCD Date Work Completed: 12-8-97
Address (Agency): PO Box 61, Gatesville,� NC 27938 Phone No.: 252-357-0290 ext 3
Signature:
C) Runoff Controls from Exterior Lots (RC)
Facility with exterior lots
Methods to minimize the run off of pollutants from lounging and heavy use areas have been installed as specified in
the plan. ,
For facilities without exterior lots, no certification is necessary.
Name of Technical Specialist (Please Print): Dennis E. Utt
Affiliation Gates SWCD Date Work Completed: 12-30-97
Address (Agency): PO Box 61, Gatesvilie, NC 27938 Phone No.: 252-357-0290 ext. 3
Signature: Date: 6 - S- o z
D) Application and Handling Equipment installation (WUP or 1:)
54 Animal waste application and handling equipment specified in the plan is on site and ready for use: calibration
and adjustment materials have been provided to the owners and are contained as part of the plan.
❑ Animal waste application and handling equipment specified in the plan has not been installed but the owner has
proposed leasing or third party application and has provided a signed contract: equipment specified in the
contract agrees with the requirements of the plan; required buffers can be maintained: calibration and
adjustment guidance have been provided to the owners and are contained as part or the plan.
Name of Technical Specialist (Please Print): Dennis E. Utt
. '-GTtt3'tii :
Affiliation Gates SWCD Date Work Completed. 7-23-96 -
Address (Agency)- PO Box 61, Ga/t�es�ville, NC 27938 _Phone No.: j252p.357-0294 xt. 3
Signature: _ � ,r„h16s� . ( _ _ ,Date: - rZS --dz,
A%VC -- Deccmher -5, 2000 d
I�G[�-D1SGi iARGE PFRtf iT sit � .4$

D)• ARlalication and Handling Eguiment
Check the appropriate box
3 Existing or expanding facility with existing waste application equipment (WUP or 1)
Animal waste application equipment specified in the plan has been either field calibrated or evaluated in accordance
with existing design charts and tables and is able to apply waste as necessary to accommodate the waste
management plan: (existing application equipment can cover the area required by the plan at rates not to exceed
either the specified hydraulic or nutrient loading rates, a schedule for timing of applications has been established;
required buffers can be maintained and calibration and adjustment guidance are contained as part of the plan).
❑ New, expanded. -or existing facility without existing.waste api lication aggipment For. &Ay irritraiiod, (I)
Animal waste application equipment specified in the plan has been designed to apply waste as necessary to
accommodate the waste management plan, (proposed application' equipment can covet the area required by ttie' plan
at rates not to exceed either the specified hydraulic or nutrient loading rates; a schedule for timing of applications
has been established: required buffers can be maintained; calibration and adjustment guidance are contained as part
of the plan).
Q New, expanded. or existing facility without existinwaste a��lication equipment_ for land spreading not using spray_
irrigation. (WUP or 1)
Animal waste application equipment specified in the plan has been selected to apply waste as necessary to
accommodate the waste management plan; (proposed application equipment can cover the area required by the plan
at rates not to exceed either the specified hydraulic or nutrient loading rates; a schedule for timing of applications
has been established: required buffers can be maintained; calibration and adjustment guidance are contained as part
of the plan).
Name of Technical Specialist (Please Print): Dennis E. Utt
Affiliation Gates SWCD _ _ _ Date Work Completed: 7-23-96
Address (Agency): \PO �)x 61, Gatesville, NC 2793$ Phone No.: 252-357-0290 ext.3
Signature: /_]o,�,�<�.. �. - - _Date:- 6 .,2, r.d2_ -
E) Odor Control. Insect Control, Mortality Management and Emergency Action Plan (SD
Sl. WUP. RC or 1)
The waste management plan for this facility includes a Waste Management Odor Control Checklist, an Insect Control
Checklist, a lvlortality Nianaaement Checklist and an Emergency Action Plan. Sources of both odors and insects have
been evaluated with respect to this site and Best Management Practices to Minimize Odors and Best Management
Practices to Control Insects have been selected and included in the waste management plan. Both the Mortality
Management Plan and the Emergency Action Plan are complete and can be implemented by this facility.
Name of Technical Specialist (Please Print): Dennis E. Utt
Affiliation Gates SWCD Date Work Completed: 12-8-97
Address (Agency): Gates SWCD Phone No.:�252-357-0290 ext.3
Signature:
Date: C-ls^-0
F) Written Notice of New or Extending Swine Farm
The folio -wing signature block is only to be used for new or expanding swine farms that begin construction after June
21, 1996. If the facility was built before June 21, 1996, when was it constructed or last expanded
I (we) certify that I (we) have attempted to contact by certified mail all adjoining property owners and all property owners who
own property located across a public road, street, or highway from this new or expanding swine farm. The notice was in
compliance with the requirements of NCGS 106-805. A copy of the notice and a list of the property owners notified is
attached.
Name of Land Owner:
Signature: Date:
Name of 1Nlanager (if different from owner):
Signature: Date:
, a . , 1, —..-__1-_._ C ^f 11f111

E) Odor Control, Insect Control and Mortality Management SD SI WUP, RC or 1)
Methods to control odors and insects as specified in the Plan have been installed and are operational. The
mortality management system as specified in the Plan has also been installed and is operational.
Name of Technical Specialist (Please Print): Dennis E. Utt
Affiliation Gates SWCD Date Work Completed: 12-8-97
Address (Agency): PO Box 61, Gatesville, NC 27938 Phone No.: 252-357-0290 ext. 3
Signature:_ 1 _ . � _ _Date: -,U- off
Please return the completed form to the Division of Water Quality at the following address:
Department of Environment and Natural Resources
Division of Water Quality
Non -Discharge Compliance & Enforcement Unit.
1617 Mail Service Center
Raleigh, NC 27699-1617
Please also remember to submit a copy of this form along with the complete Animal Waste
Management Plan to the local Soil and Water Conservation District Office and to keep a copy in
your riles with your Animal Waste Management Plan.
AWC -- December "2000

GATES
COUNTY
-opus"
COUNTY
MERCHANT MAPS
I I THE FRIENDLY STORESI Efl-
jimmirs "" :
-GATES.COYNH.

Producer:
Location:
Address:
Telephone:
Type of Operation:
Number of Animal Units
Paul Lilley
NC 37 1 Mile of Gatesville, NC
146 NC 37 South
Gatesville, NC 27938
252-357-2575
Swine
Wean to Feeder — 180
Feeder to Finish — 450
Farrow to Wean - 20
Cri
The waste from your animal facility must be land applied at a-spccified rate to prevent pollution of surface
and/or ground water. The plant nutrients in the animal waste should be used to reduce the amount of
commerical fertilizer required for the crops on the fields where the waste is to be applied. This waste utilization
plan uses nitrogen as the limiting nutrient. Waste should be analyzed before each application cycle and annual
soil tests are strongly encouraged so that all plant nutrients can be balanced for realistic yields of the crops to be
grown.
Several factors are important in implementing your waste utilization plan in order to maximize the fertilizer
value of the waste and to ensure that it is applied in an environmentally safe manner. Always apply waste based
on the needs of the crop to be grown and the nutrient content of the waste. Do not apply more nitrogen than the
crop can utilize. Soil types are important as they have different infiltration rates, leaching potentials, cation
exchange capacities, and available water holding capacities. Normally, waste shall not be applied to land
eroding at greater than 5 tons per acre per year. With special precautions, waste may be applied to land eroding
at up to 10 tons per year. Do not apply waste on saturated soils or on land when the surface is frozen. Either of
these conditions may result in runoff to surface waters, which is not allowed under DEM regulations. Wind
conditions should also be considered to avoid drift and downwind odor problems. To maximize the value of
nutrients for crop production and to reduce the potential for pollution, the waste should be applied to a growing
crop or not more than 30 days prior to planting. Injecting the waste or disking will conserve nutrients and
reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content for this type of
facility. Actual acreage requirements may be more or less and should be based on the waste analysis report
from your waste management facility. You will find information on proper sampling techniques, preparation.
and transfer of waste samples to the lab for analysis in your Certified Operators manual.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A• N(A0.1 2H.0217
- ECTK-
adopted by the Environmental Management Commission. r - --- - --- ---
JUL Q 2002
J-1.)H-1)1SGHAF'.(:-. Pry..

� 1
1 t�.0 ,..,.
E 'VTI L�?� A'� k,WAST�
FOR,SWINE�OPI
Amount of Waste Produced per Year
20 sow farrow to wean X 3203 = 64,060 gal.
180 pig wean to feeder X 191 = 34,380 gal.
450 hog feeder to finish X 927 = 417,150 gal.
Total gal.
Amount of Nitrogen {N) Produced per Year
20 sow farrow to wean X 5.4 = 108 lbs.
180 pig wean to feeder X 0.48 = 86 lbs.
450 hog feeder to finish X 2_3 = 1,035 lbs.
515,590 gal.
Total lbs. 1229 lbs.
Applying the above amount of waste is a big job. You should plan time and have appropriate equipment to
apply the waste in a timely manner.
See attached map(s) showing the fields to be used for the utilization of animal waste. The following acreage
will be needed for waste application based on the crop to grown and method of application:
2

t
r , l WASTE AUTILIZATION .PL`AN r, E
�P 3� 3 lit ✓. ,3 3i� 4 �� �fE6' i 4 3,e 3 � r< � u$� "9°!• 3
R i s' Ni7N� T�+l N
60,1.w.sS�pl \ lJ �01 i'IOIl \..
j
June,25, 2002
Table 1: Acres Owned by Producer
Tract
No.
Field
No.
Soil
Type
Crop
Realistic
Yield/Acre
Lbs./N
Per Acre
Acres
Lbs./N
Utilized
Month of
Application
92
1
RoA
Fescue
2.5 Tons
125
6.8
850
Feb. - Oct.
92
2
RoA
Corn
120 bushel
150
6.2
930
Mar, - .Iitly
92
4
AtA
Corn
130 bushel
163
4.4
717
Mar. -- July
92
5
ToA
Corn
130 bushel
163
13.5
2200
Mar. - July
92
7
AtA
Corn
130 bushel
163
4.0
652
Mar. -- .ILEIy
92
8
AtA
Corn
130 bushel
163
3.0
489
Mar. - July 2
TOTALS
37.9
5838
m
Tract
No.
Field
No.
Soil
Type
Crop
Realistic
Yield/Acre
Lbs./N
Per Acre
Acres
Lbs./N
Utilized
Month of
Application
92
1
RoA
Fescue
2.5 tons
125
6.8
850
Feb. - Oct.
92
4
AtA
Cotton
850 lbs.
102
4.4
449
May -- July
92
-4
AtA
Wheat
50
4.4
220
Oct. - Mar.
92
7
AtA
Cotton
850 lbs'.
102
4.0
408
May -July
92
-7
AtA
Wheat
50
4.0
200
Oct.
92
8
AtA
Cotton
850 lbs.
102
3.0
3U6
May - July
92
- 8
AtA
Wheat
50
3.0
150
Oct. - Mar.
TOTALS
18.2
2583
OR
Tract
No.
Field
No.
Soil
Type
Crop
Realistic
Yield/Acre
Lbs./N
Per Acre
Acres
Lbs./N
Utilized
Month of
Application
92
1
RoA
Fescue
2.5 tons
125
6.8
850
Feb. -- Oct. T'
92
2
RoA
Wheat
55 bushel
132
6.2
818
Nov. - Mar.
92
2
RoA
Soybeans
44 bushel
88
6.2
546
May - Aug.
92
4
AtA
Wheat
60 bushel
144
4.4
634
Nov. - Mar.
92
4
AtA
Soybeans
45 bushel
90
4.4
396
May - Aug.
92
5
ToA
Wheat
60 bushel
140
13.5
1890
Nov. - Mar.
92
5
ToA
Soybeans
45 bushel
90
13.5
1215
May -- Aug.
92
7
AtA
Wheat
60 bushel
144
4.0
576
Nov. - Mar.
92
7
AtA
Soybeans
45 bushel
90
4.0
360
May - Aug.
92
8
AtA
Wheat
60 bushel
144
3:0
- 432 . ,
? -�N6v, - Mara
92
8
AtA
Soybeans
45 bushel
90
3.0
TOTALS
37.9
7P87 19
2002
3 i�l� DISChl�11GF PEi;t',';`

F �a WASTE U€ I1L ZA'I110, ,PLAN OPERATION
3 tine 25; 20
2
OR
If Crop Rotation Follows Soybeans Use This Table
Tract
No.
Field
No.
Soil
Type
Crop
Realistic
Yield/Acre
Lbs./N
Per Acre
Acres
Lbs./N
Utilized
Month of
Application
92
1
RoA
Fescue
2.5 Tons
125
6.8
850
Feb. — Oct. 1
92
2
RoA
Corn
120 bushel
130
6.2
806
Mar. — July
92
4
AtA
Corn
130 bushel
143
4.4
629
Mar. — July
92
5
ToA
Corn
130 bushel
143
13.5
1931
Mar. — July
92
7
AtA
Corn
130 bushel
143
4.0
572
Mar. — July
92
8
AtA
Corn
130 bushel
143
3.0
429
Mar.
TOTALS
37.9
5217
OR
Tract
No.
Field
No.
Soil
Type
Crop
Realistic
Yield/Acre
Lbs./N
Per Acre
Acres
Lbs./N
Utilized
Month of
Application
92
1
RoA
Fescue
2.5 tons
125
6.8
850
Feb. — Oct.
92
4
AtA
Cotton
850 lbs.
82
4A
361
May — July
92
—4
AtA
Wheat
50
4.4
220
Oct. — Mar.
92
7
AtA
Cotton
850 lbs.
82
4.0
328
May — July
92
—7
AtA
Wheat
50
4.0
200
Oct. — Mar.
92
8
AtA
Cotton
850 lbs.
82
3.0
246
May — July
92
—8
AtA
Wheat
50
3.0
150
Oct. — Mar.
TOTALS
18.2
2355
1/ This N is from animal waste only. If nutrients from other sources such as commerical fertilizer are
applied, they must be accounted for. Total N must be based on realistic crop yield expectation.
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N requirellicnts.
Beginning in 1996 the Coastal Zone Management Act will require farmers in some eastern
counties of North Carolina to have a nutrient management plan that addresses all nutrients. This
waste utilization plan only addresses nitrogen.
2/ (---) -= Overseeded
4

F 01
':j j
41
Table 2:
t , P
2002,��
Application of Waste by Irrigation
Tract
No.
Field
No.
Soil
Type
Crop
Application
Rate (In./Hr.)
Application
Amount (In.)
92
1
RoA
Fescue
0.35
0.5
92
2
RoA
Corn
0,35
0.5
92
2
RoA
Wheat
0,35
0.5
92
2
RoA
Soybeans
0,35
0.5
92
5
ToA
Corn
0.35
0.5
92
5
ToA
Wheat
0.35
0.5
92
5
ToA
Soybeans
0.35
0.5
92
4,7,8
AtA
Corn
0.5
0.5
92
4,7,8
AtA
Cotton
0.5
0.5
92
4,7,8
AtA
Wheat
0.5
0.5
92
4,7,8
AtA
Soybeans
0.5
0.5
JUL P
NOW -DISCHARGE
L.-,- --

WASTE.,,UTIL'IZATION PLAN;,".
F R? WI�,� fEs�
OPERATION -
",ION
Y tF { ,n 1 E Etc 9 R5:3 _ ''• 1 �R . _ . .
FEp
¢Y 2QO2!
WASTE DISPOSAL SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade conveyances, direct
application, or direct discharge during operation or land application. Any discharge of waste, which
reaches water, is prohibited.
2. There must be documentation in the design folder that the producer either owns or has an agreement for
use of adequate land on which to properly apply the waste. If the producer does not own adequate land
to properly dispose of waste, he/she shall provide a copy of an agreement with a landowner 1hal is
within a reasonable proximity, allowing him/her the use of the land for waste appiicat1011. 1L is thu
responsibility of the owner of the facility to secure an update of the Waste Management Plan when there
is a change in the operation, increase in the number of animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for realistic crop yields based
on soil type, available moisture, historical data, climatic conditions, and level of management, unless
there are regulations that restrict the rate of application for other nutrients.
4. Animal waste shall be applied on land eroding less than 5 tons per acre per year. Waste may be applied
to land that is eroding at 5 or more tons but less than 10 tons per acre per year providing grass filter
strips are installed where runoff leaves the field. (See FOTG, Standard 393 — Filter Strip)
5. Injecting the waste or disking after waste application can reduce odors. Waste should not be applied
when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated on
conventionally tilled cropland. When applied to conservation -tilled crops or grassland, the waste may
be broadcast provided the application does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina" for guidance.)
7. *Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff does nol
occur offsite or to surface waters and in a method, which does not cause drift from the site during
application. No ponding should occur in order to control odor or flies.
S. Animal waste shall not be applied to saturated soils, during rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that the crop is not covered
with waste to depth that would prohibit growth. The potential for salt damage from animal waste should
also be considered.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a high
potential for leaching. Waste nutrient loading rates on these soils should be held to a minimum and a
suitable winter cover crop planted to take up released nutrients. Waste shall not be applied more than 30
days prior to planting of the crop or forages breaking dormancy.
6

p , a WASTE,U i,ILZZATION PLAN
'erIn.
�j
TOR -SWINE
WASTE DISPOSAL SPECIFICATIONS
11. Animal waste (other than swine waste from facilities sited on or after October I, 1995) shall not be
applied closer than 25 feet to perennial waters. (See Standard 393 — Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those owned by the
landowner.
14. Waste shall be applied in a manner not to reach other property and public right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands by a discharge or
by over -spraying. Animal waste may be applied to prior converted cropland provided a "Technical
Specialist" has approved them as a land application site. Animal waste shall not be applied on grassed
waterways that discharges directly into water courses, and on other grassed waterways, waste shall be
applied at agronomic rates in a manner that causes no runoff or drift from the site.
16. *Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall not be
discharged into the animal waste management system.
17. •A protective cover of appropriate vegetation will be established on all disturbed areas (lagoon
embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to protect the vegetation.
Vegetation such as trees, shrubs, and other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible. Berms and structures should be
inspected regularly for evidence of erosion, leakage, or discharge.
18. off animal production at the facility is to be suspended or terminated, the owner is responsible for
obtaining and implementing a "closure plan" which will eliminate the possibility of an illegal discharge,
pollution and erosion.
19. • Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular basis to prevent
breakdowns, leaks, and spills. A regular maintenance checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops for direct human
consumption. However, if animal waste is used on crops for direct human consumption it should only
be applied preplant with no fi►rther applications of animal waste during the crop season.
21. *Highly visible markers shall be installed to mark the top and bottom elevations of the temporary
storage (pumping volume) of all waste treatment lagoons. Pumping shall �e_managed..to.,ivaintarn the
liquid level between the markers. A marker will be required to mark the maximum. sOorage v_.ofuIne for
waste storage ponds. u..
€a jN-DISCHARGE PEM,, — �r

1
WASTE DISPOSAL SPECIFICATIONS
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least annually at crop sites
where waste products are applied. Nitrogen shall be the rate — determining element. Zinc and copper
levels in the soils shall be monitored and alternative crop sites shall be used when these metals approach
excessive levels. Phosphorus shall be adjusted for optimum crop production and maintained. Soil and
waste analysis records shall be kept for five years. Poultry dry waste application records shall be
maintained for three (3) years. Waste application records for all other waste shall be maintained for five
(5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina regulations.
*Liquid Systems
8

' WASTE UTTIETEATION� PLAN,,
ham.., "" ��Si• { [ Ly.� �,..:..
$WINE„.OPERATION
June 2S; 2002'6.h a -
.»c:.
Your facility is designed for 120 days of temporary storage and should have the temporary storage removed on
the average every 4 months. In no instance should the volume of waste being stored in your structure exceed
elevation 50.6.
Call the Natural Resources Conservation Service or Gates Soil and Water Conservation District office after you
receive the waste analysis report to obtain assistance in determining the amount per acre to apply and the
application rate prior to applying the waste.
Note: Sludge disposal is an item that will need to be addressed every 5-7 years. Your facility will
provide approximately 562 pounds of plant available nitrogen (PAN) per year in the sludge. If
you remove the sludge every 5 years, you will have approximately 2810 pounds of PAN to
utilize. If you apply the sludge to corn at the rate of 125 pounds of nitrogen per acre, you will
need 22.5 acres of land. Please be aware these are only estimates of the PAN and acres needed.
Actual application rates will be based on a waste analysis of the sludge after the sludge has been
agitated, and the realistic yield expectations (RYE) of the host crop.
Narrative of Operation: This Waste Utilization Plan (WUP) has been amended to reflect the crop rotations
used by this operation. Table 1 shows the receiving crops and computations. This will allow the producer more
flexibility in managing the wastes produced, and provide an opportunity for crop rotations. The acreage shown
in Table 1 represent the minimum wetted acres needed for each crop. Field 1 is fescue pasture and is being .
grazed. The wheat/soybean rotation will be a double crop with the wheat being harvested. The soybean RYE
has been reduced to allow for application on the wheat. Any crop rotation following soybeans will have the
pounds of Nitrogen (N) reduced by 20 pounds to account for the N residue from the soybeans. When the cotton
rotation is used, wheat will be overseeded (—) to allow a fall application. The wheat will not be harvested and
the pounds N per acre has been reduced to reflect this. These rotations or combination of rotations along with
the fescue pasture will allow full use of the N produced (1229 pounds) by this operation per year. A traveling
gun irrigation system is used for waste application.
Note: This WUP was amended this date per request of Division of Water Quality (J. R. Joshi) to reflect DWQ
changes for General Permit.
9

Waste Utilization Plan Agreement
I (we) understand, will implement and follow the specifications and the operation and maintenance procedures
established in the approved animal waste utilization plan for the farm named above. I (we) know that any
expansion to the existing design capacity of the waste treatment and/or storage system or construction of new
facilities will require a new utilization plan and a new certification to be submitted to DWQ before the new
animals are stocked. I (we) also understand that there must be no discharge of animal waste from this system to
surface waters of the state for any reason except storm events as severe as the 25-year, 24-hour storm or greater.
The DWQ regulations require a copy of the approved plan be filed on site at the farm office and at the local Soil
and Water Conservation District and will be available for review by DWQ upon request. Failure to comply
with the waste utilization plan will automaticalk require any cost share funds to be refunded to their source.
1
Name of Facility Qwner (Please Print): 4 1 41,'`><
Signature:
Name of Manager (If Different from Owner):
Signature:
Date: C. � �-- U�
Date:
Where owners of animal operations do not have adequate amounts of land to apply the waste, the producer must
provide a written agreement whereby another landowner has agreed to land apply or allow land application on
his or her land. The attached agreement may be used or some other documentation may be provided.
Adiacent Landowner Agreement
I, , understand that Mr./Mrs, does not have ample
land to apply the animal waste produced from his/her animal operation. 1 agree and give permission f'or
Mr./Mrs. to apply animal waste from his waste system on acres of
my land for the duration of time shown below.
I further understand that this waste contains nitrogen, phosphorous, potassium, and other nutrient elements and
when properly applied should not harm my Iand or crops. I also understand that the use of this waste will
reduce my need for commerical fertilizer.
Term of Agreement: to
(Minimum of ten years on cost shared items)
(See specification No. 2)
Recipient Landowner (Please Print):
Signature:
Date:
JUL 9 2002
10 r �l4Oi-4-blSCHF;FiC7E PER'""T

WASTESUTILIZATIC
4
d�.l � FOR.<SWT�NE OP$$ER
' 1
�A.June-25, 1002
Plan Approval
Name of Technical Specialist (Please Print): A-M A-0
Affiliation (Agency):
Address: , d 16
U IG /P. C`
,1`�1 V1V
I I
M
i
Signature:/! Ag/ rate: 6 -,S OZ_
SWCD Board Review
SWCD Representative (Please Print):
Signature:A Z/ , Date:

1
16-
7rrW
00
u

.I..
Obtain
1-F:Cla..ki.red permits (026, 401., 404,
dam sc-lfety, etc. )
7.
2
Hazzkvd
Classification Sheet (NC--ENE--34)
EA . Geodetic mar.:) showing lagoon location, distance to nearest
residence, and breach route
',:oi.). Investigxati.on SYlee
f�I a . Investigation made by S)o i l Scientist avid/or E=;+`1c3 i1'leexl- with
Inack;hoo on Class 1'l1 or IV lcagoo1"1s, as well As C.+tho1-
gl.1e sti.r;+nable sites. Investigation to be coorc.Ii.nated with
State E--rigineer's o'ffi.ce [_+1"1 Blass V 1ageo1-1s
b. Pits 1..0' 2.0' below designed bottom of 1ar.�ct�ra
;_. Seast.;+nc'al and perma'ane1 wate1- table depths rec(:+rded
t l . I.._ (:! C_ r"3 'i R C� i'� <"l 1'1 C:� !".� i. frl L .1"1 _s i. U 1"i -> o ' ' � . a C, J C:s ii 11 <=1 i-i C i k_I :I. . t ]. I"l r f"-.s
I._ocat:irn and e-.levati(:,rl of soil pits
w cr fri.pe'
C.w:s C.i 1 f" �a C E' :l '�: £=� r r t..a FIl C1 ` as .. { C3 i. v e r s r, .� 1 cF 1"1.::,
d r',ortl"1 arrow
C.? . D is l- scalp
ml_4:'at% FIl IVf:+ a scale of or less,
113to1"'age vo).UME"S (�11"E?3l..ICIF? SF:?1 E?ili.ltahef?t)
R- 1R...,n:si.i'jnE' d wA.urm•:? evc6'1ecki5 needs .
I::l All temporary storage -itt-1-ed above seGason,:.al high water
t a b 1.
Miriifn[AM 6 ft. dc=+PIth ,Al 1. +:_k_l. -ft. pel- pCtik.1lrld of st - Idy
w, t":fit e 1. i.ve wei.gI"kt for treatment vo lurn ?
p6. f. xc_%:avGati ovi and f'i.l.:l. f.;_a3.C:l..klat;itWns (i.l-1C.-JUdC; bl..li.ldi.rlg pad 'f.-111 )
7 . I...•aea¢-+c+n 13urnmary Sheet & Typ i.ca l Cross -Section ( area form)
ff 8. Construct].on Specifications (area form)
1.
t7 i . Waste hlanz-agement F,1. an ( clrc+a -fC1rm )
t G,. „Soil survey sheets showing all fields and suitability of
c- r- t ., p t.,y
b.-i.gnF).ture:s of producer and pei-Fon preparing plan
C. A+. rC...)efk1C!1-1t: S;hC.2ra{a s il"led Fly %cld o i ri "L rig 3. "a rid k-,wr'lrol'- { i f 1'1eeded
d. Tvic_lude �attr-al:_hfflellt "f " 01-1 S.k(Y1p3.i.r1g proC.•edUre
10 7'1 txr1_'afer f='k..[mp a11ci SU(np 1)Esi.Cj1-1 {1f needed)
I I Op Dration and Maintenance Fol art (ar-ea for al)
r:)esigned by: � W _ _----_-___ Date: IJ1rG
Apf:11•-(sved by: ���+_+!� �_..._.__.........__.....__.__._.�--._ ��te: .G.[.'._��._.._�r.-9�

1 Cfi! i`4
E A 5 3& 4
GENERAL INFORMATION
ADDRE;.'35 2'
W alei V1,Ae_z�g3�
L.t:3CAT I Ot+l
ti 4aJ,_ 39 2S 'p p
G �G
TYPE OF OPERATION
RoS&%& �;;;W A
SIZE OF OF'ERAT I ON �,; Tys iV f —
LOCATION DATA
DISTANCE FROM NEAREST RESIDENCE NOT OWNED BY PRODUCER
l2SU FEET.
Ic; Sl:-rE WITHIN 3.00---YEAR FLOOD PLAIN? YES __ X
IF YES, SCS CANNOT PROVIDE ASSISTANCE. _ NO __�r
IS G ]: -1-E A"I" LEAST FEET FROM A "FLUE LINE" PE RE NN I f' L STREAtI7
YES X NO
IF NO, SITE MUST BE RELOCATED.
IS SITE WITI-tl'N 100 FEET OF A WELL?
IF YES, SITE MUST BE RELOCATED.
YES NO
IS SITE WITHIN I MILE ZONING JURISDICTION OF A MUNICIPALITY?
YES _X . NO
IF YES, LANDOWNER WILL CONSULT WITH LOCAL ZONING BOARD
ABOUT REQUIRED PERMITS. PERMITS MUST BE OBTAINED PRIOR TO
DESIGN APPROVAL.
ARE UT I L T. ,r m.s. WITHIN THE:. CONSTRUCTION AREA? YES NO X__
IF YES, SEE PART 503 OF THE NATIONAL ENGINEERING-MANUAL�AND
FOLLOW POLICY. 1
(COPIES OF MAPS OR OTHER REFERENCE MATERIALS MAY BE
ATTACHED TO SITE EVALUATION.)
POPP 1

26/54
EAS3&+
±I• ..+x. •�:r .� 'i +� ' i+ .-R+�+t fie:':: �'�►�+i ::R'���. ''��'''+ `?�*Me. . '.�+ S� r�'a'�ii!' °i<ii'>'.?i 'w :�!M�:i�i•°a'a;i�•',•i •: � , -'�'w'� ,'
WETLANDS
WILL SITE INVOLVE CLE (IiR I NG WOODLAND OR ANN' NON —CROPLAND?
YES __.._ NO IF YES, YES, LAND --OWNER MUST COMPLETE A FORM AD-1026.
W I: L...L. ACTION I ESL.Jl....T IN SWAMP•-BusT I NG? YES NO ,X _
IF WETLANDS ARE INVOLVED, IT IS THE RESPONSIBILITY OF THE
LANDOWNER TO CONTACT THE US ARMY CORP OF ENGINEERS AND THE
DIVISION OF ENVIRONMENTAL MANAGEMENT TO DETERMINE IF
ADDITIONAL PERMITS ARE REQUIRED_ NO WETLANDS SHOULD HE
ALTERED UNTIL PRODUCER RECEIVES WRITTEN APPROVAL FROM SCS,
US ARMY CORP OF ENGINEERS AND NC DIVISION OF ENVIRONMENTAL
MANAGEMENT.
(A COPY OF AD-1026 AND CPA-026 WILL BE ATTACHED TO THIS
SITE EVALUATION.)
OTHER ENVIRONMENTAL FACTORS
IS ENI)ANGERED AND/OR THREATENED SPECIES HABITAT F''RESENTI,
YES NO A
IS A D[:*;3 I GNATE•,D tlAT URAl_ SCENIC AREA INCLUDE]) IN THE PL..ANN I NFj
AREA OR WILL PLANNED ACTIONS IMPACT ON AN ADJACENT NATURAL.
SCENIC AREA? YES NO
IS AN ARCI-IAEOLOG I CAL OR HISTORICAL SITE LOCATED IN THE PLANNED
AREA" YES _ - NO �_ {
IS THERE PRIME, UNIQUE, STATE OR LOCALLY IMPORTANT FARMLANDS
I. t,i -rHE OPERATING UNIT? YES _ NGa _
WILL THIS ACTION RESULT I: N SODBUST I NG? YES _ NO
IF THE ANSWER TO ANY OF THESE QUESTIONS IS YES, REFER TO
FORM NC—CPA--16 FOR POLICY SOURCES. THE FORM DOES NOT NEED
TO BE COMPLETED.
ODOR CONTROL
I -IA S ODOR CONTROL. BEEN DISCUSSED WITH THE PRODUCER- WITH
.... l'-,REDOM I NANT WIND DIRECTION? YES NO
.. , PRECHAR13 I N(i) LAGOON WITH FRESH WATER TO AT L.EAS'T
.1 /2 OF THE CAF'AC I TY? YE_ S x NO
.... USING G'001] SOUND ;.1 UDGMEN..I.. IN LAND AT"FIL. I CAT I Oh.
CIF WASTE? YES _ _ NCa _---

'3b194
'EAS 3 & 4
•':'.�:''`f'� � :::y"�*',:::.::...�*�!.�<::,�;:!��':�i�i'�»:E,.�'�..'.. Ems'>�:•.
''::5.'5�;,;.s:.:.:{ti'ti?iiii•i•••::.:{'ii{+�i'{•:i {S4•{., ..: ::: ::.:r.: {r .:
... ...... ...:r... .... ..... :}$:.7:^. .. v... ...:.......................,..r.................. a.......... rs. n.... .... 5. .... S. SS.• .s ....s ...:. . s.
::: r:: :�::..: :�:'...... r, :••:. ::•:: •.. r... ...:::::. n.rr$:•;.'...:i•'... r.: ::•... ..r,�.:.::::r:r.::... ....... :+: •'.
.r.�. .:;.•.:. :•:...• ................. ...... S•. ,..: ... ... Shsr {. sF..Ssi'�;;{;;{::-';isS'is:,'.'•.'•'i:i$rti.`•✓'r:•::ri
WASTE MANAGEMENT
DOES THE PRODUCER OWN ENOUGH LAND -rO PROPERLY LAND APPLY
"L kIE WASTE? YES �< _ NO '---
IF NO, DOES THE PRODUCER HAVE ACCESS TO MORE LAND?
YES NO
IF LAND IS NOT OWNED BY THE PRODUCER, CAN THE PRODUCER GET
AN AGREEMENT ON LAND ON WHICH TO APPLY WASTE?
YES NO
ATTACH A COPY OF THE WASTE UTILIZATION PLAN TO THIS SITE
EVALUATION.
SOIJ... T.NVE_-: F3TIGATTON
IS i.OIL_ GUITA13LE FOR LAGOON? YES NO
IS A L ]: NE:R (CLAY OR SYN"i HE"r IC) REQUIRED? YES X NO
IF YES, IS CLAY MATERIAL AVAILABLE ON —SITE? YES K NO.
QUESTIONABLE
IS A CORE TRENCH REQUIRED? YES NO (
(ATTACH SOIL INVESTIGATION SHEET TO SITE EVALUATION!
6]"YE APPROVED', , YES lC_ h40 CONDITIONAL
COMMENTS
1I116 131T'E:. INVESTIGATION IS VALID FOR lel) DAYS AS LONE; AS THE
PR[IDUCE=R CONTINUES TO MAKE REASONABLE EFFORTS TO OBTAIN
REQUIRED PERMITS AND PURSUES CONSTRUCTION IN A PRUDENT MANNER.
UNDUE DELAYS OF HESITANCY IN OBTAINING PERMITS OR PURSUING
C`'01',4S:,TRULT I ON MAY REQUIRE THIS SITE. EVALUATION TO BE
I NVAL I DAT'EL) .
L.ANI)C3WNER/F'E:ODUCER Ov{!� d/""`_` _ DOTE b? '/1 "P-_
SCS/L)IS"rE;IC"E' REP. `-�__=---����-�___�_ E')ATE/2y3'_9�
PAGE 3

U. S.'Department of Agriculture NC-ENG-34
Soil Conservation Service September 1980
File Code: 210
HAZARD CLASSIFICATION DATA SHEET FOR DAMS
Landowner
/�c�
�/ //��� County
Y I e s
Community
or Group
No. G. _ Conservation Plan
No. G —/
Estimated Depth of Water to Top of Dam 3.5 Ft. Length of Flood Pool lS e> Ft.
Date of Field Hazard Investigation 2
Evaluation by reach of flood plain downstream to the point of estimated minor effect
from sudden dam failure.
.Est.
Elev. :Est.
Elevation
Kind of
:Improvements:
of Breach
Peach: Length:
Width: Slope: Land Use
Improvements
Above :Floodwater Above
Flood Plain:
Flood Plain
Ft.
Ft. . /�
7. / -4 �' G
Y t 17 �ir -
Ft
r 'y
Ft.
A
3
.
Describe potential for loss of lifed damage to existiA g or probable,�uture downstream
improvements from a sudden breach_A �eh;A. / sGo
/Va /y r al4r via G / .s--
Hazard Classification of Darn (a, b, c) (see NEM-Part 520.21)_ cZ
Dam Classification (I, II, III, IV, V)
By
name
title
SL/
Concurred By
name � title
NOTE: 1. Instructions on reverse side.
2. Attach additional sheets as needed.
Date, _ /2_-/3 -9,;
Da to

} I � 71' I � � �' ICI ��� � f �nl: /� _ - �+ `% - Y 4�:- •♦ 1 i, _ 3 � "/ •
Sr I � r - Y � J t• � _•,WA
a
NJ
fZap
rr I.. }f #.
+}r :{I L ., I H C } 1 e
1 I 1F.+## # t# il,r'rF.}�I
�_,T } If.1'_ r i kr� t }i 'T }
ITS err}' r xt
}I # I# f'#+#}y} �''' ro # �l ,, 4 : — #r#r!1
01
fl
— _
_
}
�.#!�!}rf�:�TT�#f#1#Ir�+��#+# �' +'.#'rs-� � !1 r, �_:: r. 3[.� `c.. - - , ry• - µ` -��. �3-..,
czGo
_`_� -� � °' _ ♦ _ � •
Mo
A c I
# f �7 e r�• �-1t4
T i I.T {,w .-
I ., # } s �+ #ice `�J��•' ,a
-moo._.. ' �/ A'� A / / :• m
M LVIDER 27 13 KM EASONS CROSSROADS r.9 RM .L IAIERCHANTS MILLPOND/
rp BELYlDERE I7 KM c J
S[iNBfIRY f� KM Sass I NW \

' lccat ioer� � .
wvr-. otar : G fr Ls: -
• � f
• _y . • ry<,---- i{etoirtrlUutla, -•--� - i • .
sP
1
Tlc;rr TsLit E;ers;F4911 eiter�_
s

4+ng
w
iIPf IlmMl
TM0-.A
,
0+M
1;a04M
�.
PtFAPrTMtNT CW.AQN$CULTU*t�i,1
SM, OONSMAYM SIRMt
SOIL INVESTIGATION M DETERMINE SUITABILITY OF PROPOSED POND SITE
PAWaR'S NAME - - E8V LZ Lk LL6 Y' DISTRICT
DATE -7 -1 cl - N't COUNMY an,
C. & PHOTO SHEET NO. WORK UN"
CROPLAND ACRTS PAMRR ACRES
WOOIDLAND_ ACPZ8 TOTAL - ACRM'
axEwm or PROPOSED POND SHOWING WHERIC BOIUNGS WERE MAID2 IAPOraL amlo 11 ii
Lmsew NAWMM pow.," ows" 111-6 of dM f" W�A* on skock,
9"T
A60
Oft
_
-3
1
■
•looms
■■■■■■■
■■■Ie■■
No
ME
nummmmmmmmmmmiilLqmmm
MEMO
ammosommom
111NE
1111111=1111101
NEENESE
VIENNE
■■m■i■■■■■
■■■■■■■
��■®ems
00000000000M
MONOMER■III■■©■
1
BORING NUMBER ANI) PROFILE
JWdJ& c"d list 0*w.jl0w and withmv borWas "t - then pm"&4 am* wn4 Aoprpw pit ban*" - se"we W11A " awl goo and6
Wa"Ifff�vd OR b*C& 4whdft R*CeA3d?W ShOW Wdfff MAU* 64MIFORR on dar"-Aff bOdneG.
unnin"'a
ono
a'Ejol
MMOM100
moo
0100
El
MONSON
11111110MAINEMOVINE
K
BORING:] MADF BY S7r'N_dT'? C_ e- SIGNATURIP A TM. -E At'!4,

a �. . ..
i . I I ,,. "}y •; I'^;1'L X' - �'� s rT.
Yr-• -.�y" } {a 4t .'1'-' +t 7� M �y....tr. y ti -' .� t T•
_ L r f T1i 4rs'�- �l' �i' ` tr���, •rid t ' yk u*,..;s, ,u , a - -.a tr..- Y
�i.
h''lAw1''4+•s
H5 ..'�r„`'•rY �"F.9 s'�C` t {3-r_'i•i''i.''T,d'�'�n t �{ C.'-'}`ram 'f n�i T.li-.(
JJ ri•r. 1_ $ .'ji- I I. 1 .Ns - '+'}k'. ix t.. "P x" 4; ._. @ r
.-leer.. ',,. N.•'.�� I , 1 .fi'i 4. 1 •• � � �' _1.�. .. ., '.1. ■•/': S .�.
W MATEMLA ENCOUNTERED IN-SMING&7� =
_ .......... .. '..:.:: (Use on* of systems below) ,
UNIFIED CLASSIFICATION USDA CLASSIFICATION..
GW - Wei graded gravels; gravel.'sand mis g- gravel. :.-........ _..... .... _... . _
GM -Si ty grave @: gravel -sand -silt mis----- --- -'vfs-very fine sand: ; - ,:.,..:.,_;.:�..,,._.,,.,,.• _.._.. .._ .,.....-._.__.._._._.__.....
GC -Clayey gravels: gravel-sand-CLy mix al IIIsandy loom
SW -Well graded`sand@;.sand•gravel mhg­ fal'-fine sandy looar':
SP- Poorly graded sands, d sir.=
Sll-Silty sand °��� '3 -,:,, �,., Sl evelly loan
SC -Clayey sandii; saad-clay srfxturer' : , _ _" of - iItw .. . • • .
ML -silts; silty. v. tine sands: sandy.or clayey sill,. ; s11,11silt loam <:y
CL-Clays of low to medium plasticity cl-i;lay loam
CH -Inorganic clays of high plasticity aicl'-silty clay. login
MH- Elastic silts ..._- .......�......- - -:'- sandyloam,_._-_
..:.... � act- clay., -, ..... _. .
OL-Organic silts and silty clays, low plasticity sic -silty clay
OH -Organic clays, medium to high plasticity c-Clay
1. Suitable material for embankment is available COYsa ON* (Indicate whom locutoe on t)6 skakh an
raw elMl ,
REMARKS:
G•i@6Y M g7/Z1 K r-04-azr l,2,..# .oKrnFit P-4rt K r., R r-Ac e
2 Eeplaia bawds requiring spacial attention in design (seems., emlns,.mck etc)
sA+'k.O ta'J -kv. J rLA d1Z (i'.
-D EV-i•.&k O F r=x *1 T Ka V 4Q (3 4� L.? H t7 CFO 'rw �i 1
GENERAL REMARKS:
14

4,7. 6 y9' 7 IN.3 Z
Sd.ti Sd,3
--- k9,M So,o Nq.�
PUMP Out
nonc/
GU�,s.S'1.yS ,jp,o
3.0
*3
Prv'Posed
h
?.Yap Uai :
d,7 y9,9 y9.8
f
Ti3M ! .si.
.So;•41 f7'g7 99.7
�d,
F/rv, :.gyp
.S"2.7
y9 � Al �
® SOJ I 1`Hves 7t� frGs��o.y /'�i `S
3o 0

THIS I)E:S I (:jN IS FCJR A -rWC]-•S-rAGE- LAGOON
CLIPITS NAME
TODAYS Dr:)TE - - - • ... - - - - _..._..._,.._._.._..._...... _ _ _.;
I) IS J'A NCE TO NF_AF-tiE_;w;T NONFARM RE_:S:E. I)E:NCF:
NI.1r•1E3E:1:`Z 01: F=' 1 GG WI_"Ar'JE._ :C NC3 'm FEEDE.R
NUMI:-?E F'� OF PT CAS FE= E:DER TO F I N I SF•1
NLP1BER OF SOWS FARROW TO Wf_==AN._ I NG :: _._.._,..."._.._._...._..__
NL1MPE R C)F S 0 W 5 E=AF;F;OW TO FEEDER
NUMBER OF SOWS FARROW TO FINISH
DEGREE OF ODOR CONTROL.
Oninimt-tm 1.0 cu. ft. per lb sslw)
(maxi.mL.tm B.t-) CU. 'ft. Fae1- Ib sslw)
NUMBER OF YEARS 01=- SI_-UI)GI: ACCUMULA'1- I ON = - -
T 01::' I_-E=:NC=,'rF-I AT rIORmAL. WA`ri_Tz L.EVEL_
1"OF=' W I D1-1••1 Al" NOR11AL_ WA-VER I__E= VF-.'
1ti1f7RMAL, WflTF:..R LEVEL. ELEVATION
LAGOON BOTTOM EL_EVATIOr•,E
Depth of F'erIT1.1nerit We:ltEjr C).0
(minimum depth without sludge = 6 feet)
(mirliillt_lm depth With 8lL.tdc1e = 8 feet)
F IRS,T STAGE SIDESLOPES
F I RE3_I.' STAGE FRE:EBOARL)--,__._._._____ __-----•--•-_-• ---- .
F" erfnanf7nnt Vo lt_tmc? Required 741-3 10. 0
F'el mmilr)iarlt V.O 1 L.tmE+ i" , c_l
F i. r•• v; t S t ca g i:-? "I" c l:a of D z t) i.) . i_)
I.n ,iC:u C}f• L.EigCicin at Top of, Dam
E_Lv- )g'th f).0 feet Width :: V.o
ADDITIONAL DRAINAGE AREA IN SQUARE FEET ===
(i.e. 1:at.tml7clt-lt pcnd & i_ythc1- area)
LENGTH OF PUt IP I NG
GA1__E._C. NS OF FRESH WATER ADDED DAILY
EXCESS RAINFCaI....l.... ABOVE-: EVAPORATION
25YR/24HR E:31"l'::1Rr'1
I_E NG-f'E-I AT "N:N" C:)F AI_.L. TEMPORARY rrTC1r OGE
WIDTH AT TOP OF ALL, TEMPORARY ,rORAGL:
TE=:m:,oiw-)RY STORAGE- E_ I C1CJ I D SURFACE ELEV. -,- -_• -.
SECOND STAGE BOTTOM ELEVATION
SEASONAL HIGH WATER TABL *"' ELEVATION
Depth ofI"Lm1ac�) Temporary Storage =- 3.E
SECOND E3TAGE SIDESLOF'EE:i
SIH.CCIND STAGE FREEBOARD ->
femFac:lv- lr•y E5tor".:Atli:) RegL.ti.r•C:)d 5EI170.5
'1 empor-;:•rr"y Storage F='r-civic: ed 26765. 1
SC:+C Ovid E'3t .lge Top of Dr.'1in Elevation -. :'J`C.'^..P
Irls.Ldo Difni3n"iilona of .ac ,..tour at I017 of Dam
L.angth :z 145.() feet Width = SO.()
E.ati.MAted Del:ath tCl F='t_tfnp
PAUI__ LILLL=Y
BATES
MAY 1 , 1996
1. 10 r) FEET
1 f:3i)
r.45t)
2t_)
i)
t)
c i , t_) YE=ARS3
0,c) FEDE'T
FEET
c) . Q FE'_ET
u . i) F I:"E_I..
feet
1.t):1
0. t.) FEET
cLlbic feet
ci_ibic feat
f C-3 e t
feet
23330 SQUARE FEET
120 DAYS
() GALLONS
9. t.) I NCE-IES
13').0 F=E;E'..F.
74. C) FEET
51.2 F= EET
40.o FEET
49.0 FEET
feet
C:LAbi!
cub i c
f e C..) t
fV;�et
VOIL.tme to be pumped = 3F3977 cubic_
Vi_-I.L.ime for Estimated Depth 30y321 cubi.c
Bc--�•7in F't_trnfairig E=leVati.on is 50.6 feet
Story F'umpi.ng E1evsatian is J•)E3.i_) feC?t
3.0: 1
1 . c_) FEET
feet
2.6 FEET
fLet
feat
4 See 4?#64 e c/ 51 T '! 4/��' �c%i�vc 5 I-Aen aW 04/4c e -xl,S 1,jy
L.ugvory

'
i.. I W ADY
Ca..4..ATE:«
LIVE WEIGHT
180
head
we:?anling-to--feeder
m 30 lbs. -
5400
lbs.
450
head
feeder -to -finish m
133 lbs.
60750
lbs.
E0
sows
farrow-to-'weanling
m 433 lbs. M
8660
lbs.
0
:sows
farrow -to -feeder ..
582 lbs. _
0
�. �-.
lbs.
0
sows
farrow -to --finish m
1417 lbs. --
0
lbs.
TOTAL
STEADY STATE LIVE
WEIGHT (SSLW) -
74910 t
lbs.
C. SLUDGE:: ACCUMULATION
Sludge accumulates at the rate of 0.080 cu. ft. per year
per pound of STEADY STATE LIVE: WEIGHT in swine.
Years of sludge, accumulation in design? 0.0
Sludge Volume -z 0.0 cubic fret
3. REQUIRED LIQUID VOLUME OF LAGOON
Design for 1.0 cu. ft. per pound SSLW
Total Volume (SSLW * Design factor) + Sludge Vol.t..icre
Total Volume - 74810.0 cubic feet
4. NORMAL_ LAGOON LIQUID LEVEL
Maintain normal lagoon liquid level at elevation 0.0 feet
Construct) lagoon bottom elevation 0.0 feet
Lagoon size for normal lagoon liquid volume using prismodial formula
SS/END1 SS/LND'r-'_ SS/SIDEi SS/SIDE2 DEPTH
i .0 1 .0 1 .0 1 .(:) 0.c_i
AREA OF TOP
LENGTH WIDTH
0, 0.0
AREA OF BOTTOM
Lb * Wb W
0.0 0.0
AREA OF MIDSECTION
(Lm * Wm)
0.0 0.0
0.0 (AREA OF TOP)
0.0 (AREA OF BOTTOM)
0.0 ( AREA OF MIDSECTION)
CU. YD. == LAREA TOP + (4*AREA MIDSECTION) + AREA BOTTOM:I * DEPTH/6
VOLUME_ OF LAGOON AT NORMAL LAGOON LIQUID LEVEL - 0.0 CU . FT.
VOLUME NEEDED M 74610.0 CU . FT.
.THE:. INSIDE EDGE. DIMENSIONS OF THE FIRST STAGE: AT THE
TOP OF DIKE ELEVATION ARE:
5
f1RE 0.0 y FEET BY 0.0 FEET

. OIKE
Place spoil as a continuous dike to elevation
6. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
.first stage lagoon (top of dike)
L vngt11 Width -=
0.0 0.0 0 square feet
second stage lagoon ( top of dike)
Length Width
145.0 B0.0 11.600 square feet
Additional Drainage Area
P3330 square feet
Tt3l•AL_ DA 34930 square feet
Pumping cycle to be 1.20 days.
6A. Volume of waste produced
0.0 feet.
Volume = 74810 S.SL..W * 0.0101.481. gallon/lb. SSLW/day 120
days in the pumping cycles / 7.49 gallons per cu. ft.
Volume == 12179.3 cubic feet
68. Volume e of wash water
This is the amount of fresh water used for washing floors or
volume of fresh water used for a flush system. Flush systems
that recycle the lagoon water are accounted for in 6A.
Volume :-. 0 gallons/day * 120 days in the pumping
cycle divided by 7.48 gallons per cu. ft.
Volume 0.0 cubic feet
6C::. Volume of rainfall in excess of evaporation
Use period of time when rainfall. exe_eeds evaporation by largest
amount.
Volume,:= 9.0 in * DA / IR inches per foot
Volume _ 26197.5 cubic feet
6U. Volume of 25 year •-• 24 hour storm
Volume =- 6.8 inches / 12 inches per foot * DA
Volume 19793.7 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
6A. 12179.3 cubic feat
68. 0.0 cubic feet
6C:. 26197.5 C_l..ibic feet
6D. 19793.7 cubic feet
TOTAL._ 59170.5 cubic_ feet

"7. , ' 'SE C jJND STAGEE:: DESIGN
SS/ENDS. SS/END2 GS/SIDE 1 SS/SIDE_E
3,C) 3.ii 3;0 3,0
AREA OF TOP (BELOW FREEBOARD)
LENGTH * WIDTH
139.0 74.0 10286.0 (AREA OF TOP)
AREA OF BOTTOM
Lb * W b
119.e 54.e
AREA OF MIDSECTION
(Lm * Wm) =
6565.0 ( AREA OF BOTTOM)
DEPTH
3.E
129.4 64.4 8333.4 ( AREA OF MIDSECTION)
CU . YD . -: [ AREA TOE` + (4*AREA MIDSECTION) + AREA BOTTOM] * DEPTH/6
10286.0 33333.4 6565.0 0.533
VOLUME OF SECOND STAGE BELOW FREEBOARD = 06765. 1 CU . F T .
VOLUME. NEEDED = 58170.5 CU . FT.
.
THE. SECOND STAGE FREEBOARD 19 = 1.0 FEET
THE INSIDE EDGE: OF THE: SECOND STAGE AT ELEVATION 52.2 FEET
ARE 145.0 FEET LONG BY 80.0 FEET WIDE
8. BEGIN PUMPING ELEVATION
TOTAL REQUIRED TEMPORARY STORAGE
6A. I 1 79.3 cubic feet
69. 0.0 cubic feet
6C. 26197.5 cubic feet
TOTAL PUMPED VOLUME 39376.8 cubic feet
VOLUME AT ESTIMATED PUMPING DEPTH
AREA OF BOTTOM 6565.0 sq . f t .
AREA OF TOP = 9532.2 sq . f t .
AREA OF MID -SECTION µ 7997.9 sq . f t .
VOLUMF. PROVIDED --. 20821 cubic feet
DESIGNED BY: APPROVED BY:
DATE: DATE-

d
Total Vo i umc
Grin Cell size: 2.10 by 2.09
Original. drawing scale: 50.00 ft/ln
Project; Paul Lillev
Drawing: Lagoon
Number: Waste Treatment Lagoon
Location: Gates County
Did Date: 2/26/96
Engineer: : G. Douglas ones
Owner: Paul L. i. 1 l ey
Estimator; Mark: Pollard
Prepared e•?d by: USDA--SCS using S I TEWORK,
Date: 04/18/96 Time: 08:04:03
Final surface: Permanent Treatment Volume
Initial surface: Existing
Tight Volumes
Cut s 16.89
Fill 2809.22
Difference .---------
2792.33
All volumes are in cubic yards.
r
Expansion (%)
k
KNEM
Net Impart :
Expanded Volumes
16-69
2809.2 2
.____._-.-._----- .33

Daylight Perime wo f,z---- -- L49. ?0 44.80
5'.}4�0y/y
1149. 40
1 50. 00
49.60
,1
41
20'� :
.60.00
1 49. 70
1 50. 10
50.00
r,
1
52. 70
r4
r1
♦4
X 50.00
rh
1 50. 10
50.10
�•'
fr a
.�:ww
49.20
1 50. 10
50.20
2.70
149.90
50.10
�2. 90
r r
:•
49.90
49.80
49.70
Report: Plot of all data
Protect: Paul Lilley
Drawing: Lagoon
Surface: Permanent Treatment Volume
Prepared by: USDA-SCS using SITEWORK
Date: 04z18f96 Time: 08:04:51
0 50 • 100 Scale: 50 ftfin

r �
i
Total Volume a
Grid cell size: 2.1() by 2.09
Original drr.rwing sole: 5cr.r=rc:1 ft/in
Pro je+ct: PaLt1 Li l ley
Draw irig : Lagoon
Number: Waste Treatment Lagoon
Location, Gates County
Did Date: 2/26/96
Engineer: G. Douglas Janes
Owner: Paul Lilley
Estimator-: Marti: Pollard
Prepared by: USDA--SCS USing SITEWORK
Date: C14/1E3/96 Time: 09:03:00
Fa.naI SU- 'faCe:
Existing TeMporary
Storage Volume
Ini.ti.al. SUI-face:
Permanent Treatment
VolUme
'rigi--)t VOlumeS
E .xpansiorr M
Expanded VolumeS
Cut .
29.71
o . C►CI
r 9. 11.
1194.92
CI . oo
1194.92
Dj.ffer erlae
µ 1165.21.
Net Import :
11.65.11
411 volumes are in cubic yards.

Daylight Peri
70
S r 5
40
149.40 150.00
I
b
52.90
M 49. 70 150.10
49.80
49.80
S S S
�S 5
150.10 150.20
149.90 150.10
1 49. 90 f 49. 80
49.70
Report: Plot o+ all data
Project: Paul Lilley
Drawing: Lagoon
Surfac e : Existing Temporary Storage Volume
Prepared by: USDA-SGS using SITEWORK
Date: 04f18./96 Time: 09:03:54
Scale: 50 ft�in

p!• �a KG6tvae? tt C%
THIS DESIGN IS FOR A S I: NC.31. E STAGE I_.AOC: ON
CLIENTS NAME
COUNTY
TODAYS DATE~
DISTANCE TO NEAREST NONFARM RESIDENCE - .
NUMBER OF PIGS WEAF•dl__:CNG TO irF:_EDER
NUMBER OF PIGS FEEDER TO FINISH ====---
NUt`'IE3EER OF SOWS FARROW TO WEANL_ I NG
NUMBER OF SOWS FARROW TO FEEDER ===== == .
F•dl,.Jfi' D E R OF SOWS FARROW ROW TO FINISH =--------== :>
DEGREE OF ODOR CONTROL...
(minimum 1.0 cu. ft. per -lb SSLW)
(maximum 3.0 cu. ft. per lb SSLW)
NUMBER OF YEARS OF SLUDGE ACCUMULATION ::
F'raL.EL L I LEY
BATES
MAY 21 1996
1100 FEET
i_r
it
o
1.0
TOP LENGTH AT NORMAL WATER LEVEL =--====>
[-OP WIDTH AT NORMAL WATER I_.EVE:I__-
NORMAL. WATER LEVEL ELEVATION =---___.._...____.-f
SEASONAL_ HIGH WATER TABLE ELEVATION ===r
LAGOON BOTTOM ELEVATION
Depth of Permanent Water sty
(minimum depth without sludge = la feet)
(minimum depth with sludge = £3 feet)
SIDE: SLOPES
Permanent Volume Required 0.0
.. or t _1 ._ 153EI..3
vv/. -,10.6a CXC44/wAC./*
ADDITIONAL_ DRAINAGE AREA IN SQUARE FEET:
(i.e. pumpc;ut pond & other outside area)
LENGTH OF PUMPING CYCLE =--____.___-.-•--- .
GALLONS OF FRESH WATER ADDED DAILY �---
EXCESS RAINFALL ABOVE EVAPORATION -----_..._..
'r. 5YR/c7.4HR STORM RAINFALL
FREEBOARD
ESTIMATED TOP OF DAFT ELEVATION ==x===== >
Temporary Storage. Volumes Needed 0.0
Temporary Storages Volume Provided-491152.4
..fop of Dam Elevation
Inside Dimensions of Lagoon at
Length =- -160.2 feet Width
ESTIMATED DEPTH TO PUMP
Volume To Be Pumped :---
Volume: for Estimated Depth =
Begin Pumping Elevation
Stop Pumping Elevation =_
0.0
Top of Dam
--F:?3:3 . c
0.0 YEARS
Ems. F= EET
50,0 FEET
0. 0 FEET
48. Er FEET
feet
:3.0; 1
cubic feet
cubic feet
c f SQUARE FEET
365 DAYS
Er GALLONS
0.0 INCHES
0.0 INCHES
1.0 FEET
0.0 FEET
cubic feet
cubic feet
feet
feet
0.0 FEET
0 cubic feet
0 cubic feet
50.0 feet

. .
.. .
.~S'1� .
'��TEADY STATE LIVE WEIGHT
. .
0 head
weanling
to feeder
: 30 lbs. =
0 lbs
0 head
feeder
to
finishing
x 135 lbs.
0 lbs
0 sows
farrow
to
woanling
x 483 lbs. =
0 lbs
0 sows
farrow
to
feeder x
522 lbs. =
0 lbs
0 sows
farrow
to
finish x
1417 lbs. =
0 lbs
TOTAL
STEADY
STATE
LIVE WEIGHT
(SSLW) =
U lbs
2. SLUDGE ACCUMULATION
Sludge accumulates at the rate of 0.080 cu. ft. per year
per pound of STEADY STATE LIVE WEIGHT in swine.
Years of sludge accumulation in design? 0.0
Sludge Volume = 0.0 cubic feet
3' REQUIRED LIQUID VOLUME OF LAGOON
Design
for
1.0 cu. ft. per pound
SSLW
Total
Volume =
(SSLW * Design factor) +
Sludge Volume
Tptal
Volume
= 0.0 cubic
feet
4. NORMAL LAGOON LIQUID LEVEL
Maintain normal lagoon liquid level at elevation 50.0 feet
Construct lagoon bottom elevation 48.0 feet
Lagoon size for normal lagoon liquid volume using prismodiml formula
SS/KND1 SS/END2 SS/SIDE1 SS/SIDE2 DEPTH
3.0 3.0 3.0 3.0 2.0
AREA OF TOP
LENGTH *WIDTH
AREA OF BOTTOM
Lb * Wb =
119.8 54.0
AREA OF MIDSECTION
(Lm * Wm) =
125.8 60.8
6565.0 (AREA OF BOTTOM)
7648.6 (AREA OF MIDSECTION)
CU. YD. = [AREA TOP + (4*AREA MIDSECTION) + AREA BOTTOM] * DEPTH/6
8804.2 30594.6 6565.0 0.333
VOLUME OF LAGOON AT NORMAL LAGOON LIQUID LEVEL =15321.3 CU. FT.
VOLUME NEEDED = 0.0 CU. FT.
THE SURFACE DIMENSIONS OF THE LAGOON AT NORMAL LIQUID LEVEL
ARE 131.8 FEET LONG BY 66.8 FEET WIDE
`

Place spoil as a continuous dike to elevation
0.0 meet.
6. TEMPORARY
STORAGE, REQUIRED
DRAINAGE AREA:
Lagoon ( top of dike)
Length Width
'-' 168 . 2 --f: 33 . 2 c39c:'.,"_ 4 square feet
Additional. Drainage Area
0 square feet
TO -I -AL D(•a 39224 square feet
E'C.lfr1ping cycle to be B65 days.
6A.
Vo.l+.{me of Waste produced
Volumes = 0 SSLW 0.0101.481 gallon/lb.
SSLW/day at 365
in the pumping cycle / 7.48 gallons per cu. ft.
Volume = 0.0 cubic feet
6B.
Volume of wash water
This is the amount of fresh water used for washing
floors or
volume fresh, water used for aflush system. Flush
systems that
recycle they lagoon water are accounted for in 6A.
Volumes =- 0 gallons/day 365 days in
the pumping
cycle divided by 7.48 gallons per cu. ft.
Vc-1.ume? 0.0 cubic 'feet
6C::.
Volume of rainfall in emaess of evaporation
Use period of time when rainfall exceeds evaporation
by largest
amount.
Emce_s rainfall (difference) 0.0 inches
Volume =_ 0.0 inches .* DA / 12 inches per
foot
Volume 0.0 cubic 'feet
6D.
Volume of 23 year - 24 hour storm
Volume -- 0.0 inches * DA / 12 inches per
foot
Volume = 0.0 cubic_ feet
-TOTAL REQUIRED TEMPORARY STORAGE:.'
6A. 0.0 cubic feet
6B. 0.0 cubic feet
6C. 0.0 cubic 'feet
6D. 0.0 cubic feet
.I_f.]..h.AL TEMPORARY STORAGE 0.0 cubic feet

. `
-. .
DEPTH OF STORAGE REQUIRED (ABOVE NORMAL LIQUID BLEVATION OF LAGOON)
VOLUME
OF TEMPORARY
STORAGE WHEN TOP OF
DAM IS 0
AREA OF
BOTTOM
B804.2
sq.
ft.
AREA OF
TOP
41668.6
sq.
ft.
AREA OF
MID -SECTION
= 1827.4
sq,
ft.
VOLUME
PROVIDED =
-491152.4
cubic
f(71et
THE DIMENSIONS OF THE INSIDE EDGE OF THE DAM AT ELEVATION
ARE -168.2 FEET BY -233.2 FEET
8. SET BE.GIN PUMPING ELEVATION
PUMPED STORAGE VOLUME
6A. 0'0 cubic feet
6B. 0.0 cubic feet
6C. 0.0 cubic feet
TOTAL PUMPED VOLUME = 0.0 cubic fe et
VOLUME AT ESTIMATED PUMPING DEPTH
AREA OF BOTTOM = 8804.24 sq. ft.
AREA OF TOP = 8804.2 sq. ft.
AREA OF MID -SECTION = 8804.2 sq. -ft.
VOLUMEPROVIDED = 0 cubic feet
DESIGNED BY:
DATE:
`
APPROVED BY:
DATE:

. .
.� .
.. .
. .. .
SCS - Area 4
iU19/93
Top Width
Settled Top of Dam: _ onstruct Top of Dam
Slope
Natural Ground Elev.
CU 1;-0ff TrenchY
Slope
3
Fill Yardage:
Depth determined by
SCE; on site
Width depends on equipment
*
Pipe Type & Size
see- S/U./w°'fStart--a-n-o--a�p=p-licati on
� Elev. � � elev.
0
Suppo 1,0226
\e
IL
Buttom
Bottom elev.
elev'
Seasonal High Water elev.
~
^
See llweAeel
Primary Treatment Volume Size:
Length
&Width Total Cu. Yds.
General Information
Engineering Job Class:
UHazard Class:
Animal Type: ____
Type Operation:
Num6er of Animals: '
,
NOTE: If construction is nmt started
Iwithin one y�i�lr, this plan is not valid
unt'iI a re-evaluation of the design and
f"100C] plain sa�F��y hazar6s are made.
Le COL.11-Ity
De.'signed by..

COMPACTION OF LAGOON BOTTOM AND SIDES
The presents of suitable clay material covering the area of
the proposed second stage lagoon eliminates the need to
place clay material in the bottom of the proposal Lagoon to
act as a liner. However, there is a need to reduce the
probability of seepage from the lagoon even in the existing
clay material..
The clay material in the bottom of the proposed lagoon will
be :a minimum thickest of 24 inches. Approximates 9-12 inches
of this will be loosened using a r'ipper or other"' equipment
available. After the material has been loosened it shall be
compacted by a sleeps foot roller- or ether compaction
equipment.
The minimum water- content of the soil shall be when kneaded
in the hand, the material will farm a. hall which does not
readily separate. The maximum water content is when
conditions are too wet for efficient use of loosing and
compaction equipment.
The completed job shall present a workmanlike appearance and
shall conform to the lines, tirades and elevations shown on
the drawing or as stated.

1111193
Clearing: All trees and brush shall be removed from the i.mpoLAndmerrt
area before construction is started. -rhe foLAndaati.on of the lagoon
shtzi l bei cleared (if all tre=ea, stL.cmp a, i-OOts, brush, sod, organic
soil, and debris. All stumps and all roots exceeding i inch in
diafne?tc?r- shall be removed tc1 a mini.fnUm de:•aptl'l of t fe:,c:,t.
Satisf"ac::tor•y disposition will be maaclea of all, debris. {after- clearing
is c0mp1et(,7d the fc:+c.cr7datiorl area shall bca loosened thoroughly and
raL.rghly leveled, with sUitaable equipment, before Enlacement of any
e-mbCar'lkme, rlt material.
Cutoff Trench: A cL.cto•f'f trench s-yhall be excavated tQ a mirlimr_Lm
dc:}f)th ccf'' ...... i.rrr:hes-., under the embankment. The exact depth shall be
clt--stermirieci on site by SCS. The tk-c.-3n(.-h %i.de s-1c.,peas shall he' 1-1 Or -
flatter ar'1cl the width will be K-,a mi.rli.mL.cm Of f, feet, bUt will de-perrd
c:+n the r�quipment being used. The cutc:,ff treyr`ir.:hl shall be b,ac1::#'i.11.ed
with _Cammater-ial. The trench shall be baackfilled in 9 inch
layers and compacted with a sheaepsfnot caller with as minimum of fir•
passes per unit width of fill lift. if sheepsfoc:,t roller- is not
LAGC-22d, the trench �-;hall the backfill.ed in 4 inch layers and compaction
shall. ben F+c.:lui.valerlt tc:, or better than the roc-rti.ng of till har.rl.i.11y �.rnd
ssl:ar c.�.ac:iirlcl eclL.cipmerlt cavesr the fill in sc.cchl as manner- that F.-?very pcnint
on tl"rra st-Ir'f Gac.e.5 of earch layer of' fill will be traversed by riot less
than onca tread tr-ac:hr• c-f the loaded equipment traveling in
direction parallel, to the main a::i.s of the fill.. All staarlding water
h�a11 lara removed from the trench before IaGacE:filliny is atartc?cf.
Existing Tile_ Drains -. When t i l.c.? dra i i-is aar'e MICO .lrrte3r0d , thR t i. l e.
wi.l.l be duel up and refrrove.d. The tile trench shr".all, be bac:F.:fil.le~•rd
with ca compac.ted layer of (."I_.. or C>l maU--"rial..
Excavation: Topssoi.l shall be stocked piled separately for later
use. The bottom of the lagoon shall be excavated as shown on- the
plans. Where peer-vic,L.cs material (SF, cluartz veins, etc. ) is exposod
dur-irig exxcavaation, i.t shall be uilderct..ct and backfiIled with) as
cc' -impacted layer o.F highly plaae;tic (CI-_, CH) material Gap Far-c:>:ima{:e�1y
one--' fc-c,t in thickness. Sc,7.%r i fy aar"rd compact the bottom and, whet re_+
pr-actic.aLnle, the si.dry slopes of then lagoon to decrease the
per•fne)ab i l i. ty of the Soil in the l ragoorl .
Embankment Construction: 'rhe mz�rL-eriaal plaited in the embankment
shall. be free of sod, roots, stones over six (6) i.rrches in diameter,
and other objectionable materials. C �_ materialS.a Shall
b£:? Lcr;ed in the e(Tl:)aarlkfYiont. Pe,r'vi.c:,uc, firc"rte V.Ia1. 50-1al 1. riot be LASEd in
tile efnhlcir'lE:fCr€'r'lt. con"tr-uctitan c;+f the embankment shrill be made in
layers riot to exceed 4 inchE?�-> in this.-kne?ss. Compaction shall. be
r-�c:li.aiv:alent to or- better- than the routing Of the hauling and
sEarecadi'6g equipment over the fill irr such a manner- that every point
ti
le he secr:-faace of each layer- of fill will be traversed by not le=ss
than orle tread track of the loaded equipment traveling in as
direction parallel to the main axis c:-f the fill.. If }:cans area riot
used, Of the embankment shall be made in layers nc'_it to
.l

1111/93
exceed 9 inches in thickness,and compacted with a sheepsf'oot roller
with as minimum of 4 passes per unit width of fill lift. At any time
the embankment surface becomes "slic_k:enecl" such that the succeeding
layer- will not bond to the previous layer-, scarify the previous
layer- sufficiently to assure bonding of the surfaces before
continuing with the fill operation. Construction of the fill shall.
be undertaken only at such times that the moisture content of the
fi.l.l material will permit a reasonable degree of compaction.
Construction of the embankment shall allow an additional % for
settlement. Stock: piled topsoil shall be spread over top of
embankment and outside side slopes for the establishment of
vegetation.
Pollution Control During Construction: Stripping of embankment and
borrow areas shell be done as they are needed in a normal sequence
of construction. Use temporary mulch protection on all disturbed
areas that are subject to erosion and will not have substantial
additional work per -formed for :30 days.
Vegetation: Vegetation shall be established can the slopes,
embankment top and all ether disturbed areas, except the area that
will be inundated, as specified .in the plans are soon as possible
after co"struction. Necessary steps, shall be taken to ensure that a
good stand of vegetation is established in a reaso"able amount of
time.
Seeding rates are:------- - _-- ].b. _ %q��
1b.
--.SO Ca -- 1 b . _ 1- W 1---1 U ----_--�.___.__.-
--- �r--- torts 1i.me
tons wheat straw
Permanent Stake: A permanent stake (CCA salt treated 4"x4" past o.r-
I inch diameter PVC pipe with tee) marked to indicate pumping
level elevations, shall be placed,, in the inside slope at one and of
the lagoon.
2

512/95
r,Ji ill` h: II .€VT.I F`Ls_iAEtiw�
:::..::::.....::.:....:.::.....::...... .......... ...:.......................
IC1EF`iiiTWlL7I's�
..............................
..................
Pr-Qduc.esr-: /''Ziml.. !llc. —_
Telephone: 9'i9'~ 3.5.7-_.S,7-49 .__
T y p e7 0 p e? r- a is i. C, n : sW � �� _t,_
Nufnt�e?v cif Animal Units: ��J,sow� +++ !r, ulCdHJlirq , l8o�aryt t�e+4/rnyA+
/tena&o- an0' LSD Tv/O Nsft .
"[4-1e was:,te fr'cam your- a:rnifrta 1 facility must be land applied at a
spo. cifieci rate to prevent pollution of surfacer zAnd/or- grc.iund water-.
The a p 1 a rr t 1-i L.t t i- i e n t s i rt t h ea 4-11-r i. fT1 a 1. Waste si-10 U l d b e2 Used to r- e d C.i C:• e t h'r e
:afrioi_knt c,f commercial ff.•?1'-ti-lioe1'- 1-eC;uire+d for- ti-ie c i-ops on the fioldss
wher-e the waste is to be applied. -['his wastes util.i.zatic-n plarl Uses
nitrogen ass tht:•2 limiting nuts' ierit. Waste should hc? ,:analyzed h cE-f'ov-r.-?
each application cycle and annual soil. tests are strcanClly ericoUraged
SO that all plant: rlutr'iearlts care his balanced r-ei:a1 istic yields of
thle:.1 cr-clpt%, to be gi-own.
Several fzictcir'es ai'-e i.fT1pC-1'-tcZrlt ir'i implementirlg yQUY" watsiite t.11til.i.:."zltior'1
plan in ol—del- to ma::imi zo thF? fc?M-ti l i iec- value of the waste and to
eI_I ,ur'e that it is applied in an erivi.r-onmentally safe fnanne_,n-. AI Ways
apply wci stG based c-n the, nec-nis of the C_r-op to bo gi'-olvin and th c,
nutrient content of the waste?. Do not apply more nits -ogee than the
t:rcap can i..rti li:_-Q. Soil typos <ar-e important as; I.J.1ey i.'iave dif-f"ent-ent
infilti-cation i-Hates, leaching poter-iti.als, cation exchange capacities,
and available wate?i- holding capacities. Nor-mra.11y, waste shall not be?
applied to laird eroding at gr-eater, than 5 tails per- aicr-e pe}r- Year.
With Special precautions, waste may be applied to land Pi -tiding at ufa
to IC) tens Pei- year. Do riot apply waste on satur'atec_1 soils c,r' on land
whleri thc� sst.,kvface is froze.-?"1. E1thev- of theses conditions may r-esult in
ri..inOfT tCj surface wa+ter-s which is riot allowed under DEM re?gulatioris.
Wind c:c_lriditic-ns should also be considered to avoid drift and downwind
odor- problems. -fo maximize the value of nutrients foi- crap pvc.duction
and to redc.rce the potearrtial fov- pc,llc_ltion, the wa tC? he i..cld i::ie .113E11.itMJ
to at gi-Owing c_rc�p car- )-lot mol"ea than 30 clays pr'iol- to planting.
Injecting the waste oi- dishing will conserve nc_iti-ionts and t-eac:iccc,e OdOi-
pr ob 1C..'?iiS7,.
The estimated acr-es needed to apply th-re ,-animal waste is Fused ore
t,ypI.c<.aI nc.itI iont acint{:ant 'foi- this type (-if facility. Acts al. ac_re.:age
i-equiremernts may be more or less and should be teased ovi the waste
analy-sis vepco-t from yCILxr'- waster mar'ragement facility. Attcach'ied yor.•c
Will fi.rrci i.rrfc;r'm,ii;i.earl on pi,-opear sa:tmplirig technirlUes, pi-eparation, and
tvansfer- of waste :samples to they ,lab for- analysis.
..RIiIS WEXSte Uti1.a.;.atiC+1-1 1)14%1-1, if carried OLA, mcnetsa the rec:iuii-ements
'For- with 15A NCAC 2F.I.c.i217 aadopted by they Environmental
r1aviagemi::?rlt (:Cy1T}f91i.E553.1L"�i"i.

Amount of waste oroduced per vear
animal units X waste/animal unit/year =
* 515590 gal waste/year
Amount of Nitrogen (N) produced per_ year
animal units X lbs N/animal unit/year =
* 1229 lbs. N/year
* See Attachment A
Applying the above amount of waste is a big job. You should plan time
and have appropriate equipment to apply the waste in a timely manner.
See attached map(s) showing the fields to be used for the utilization
of animal waste. The following acreage will be needed for waste
application based on the crop to grown and method of application:
Table 1: ACRES OWNED BY PRODUCER
Tract Field Soil Crop Real. Lbs. N Acres Lbs. N Month of
# Type Yield Per Ac1/ Utilized Application
92
1
RoA
Fescue
2.5ton
125
6.8
850
Feb -Oct
92
2
RoA
Corn
120 bu
150
6.2
930
Mar -Jul
92
4
AtA
Corn
125 bul
156
4.4
686
Mar -Jul
92
5
ToA
Corn
130 bu
163
13.5
2200
Mar -Jul
92
7
AtA
Corn
125 bu
156
4.0
624
Mar -Jul
92
8
AtA
Corn
125 bu
156
3.0
468
Mar -Jul
Total
37.9
5758
OR
92
1
RoA
Fescue
2.5ton
125
6.8
850
Feb -Oct
92
4
AtA
Cotton
650 lb
78
4.4
343
May -Jul
92
-4
AtA
Wheat
66
4.4
290
Nov -Oct
92
7
AtA
Cotton
650 lb
78
4.0
312
May -Jul
92
-7
AtA
Wheat
66
4.0
264
Nov -Oct
WUP - 2

1 1
1 �
ayeo-1
Table 1: ACRES OWNED BY PRODUCER
Tract Field Soil Crop Real. Lbs. N Acres Lbs. N Month of
# Type Yield Per Ac1l Utilized Application
92
8
AtA
Cotton
650 lb
78
3.0
234
May -Jul
92
-8
AtA
Wheat
66
3.0
198
Nov -Feb
Total
18.2
2491
OR
92
1
RoA
Fescue
2.5ton
125
6.8
850
Feb -Oct
92
2
RoA
Wheat
45 bu
108
6.2
670
Nov -Mar
92
2
RoA
Soybea
33 bu
132
6.2
818
May -Aug
92
4
AtA
Wheat
55 bu
132
4.4
581
Nov -Mar
92
4
AtA
Soybea
35 bu
140
4.4
616
May -Aug
92
5
ToA
Wheat
45 bu
108
13.5
1458
Nov -Mar
92
5
ToA
Soybea
33 bu
132
13.5
1782
May -Aug
92
7
AtA
Wheat
55 bu
132
4.0
528
Nov -Mar
92
7
AtA
Soybea
35 bu
140
4.0
560
May -Aug
92
8
AtA
Wheat
55 bu
132
3.0
396
Nov -Mar
92
8
AtA
Soybea
35 bu
140
3.0
420
May -Aug
Total
37.9
8679
11 This N is from animal waste only. If nutrients from other sources
such as commercial fertilizer are applied, they must be accounted for.
Total N must be based on realistic crop yield expectation.
NOTE: The applicator is cautioned that P and K may be over
applied while meeting the N requirements. Beginning in 1996
the Coastal Zone Management Act will require farmers in some
eastern counties of North Carolina to have a nutrient
management plan that addresses all nutrients. This waste
utilization plan only addresses Nitrogen.
WUP - 3

Table 3: APPLICATION OF WASTE BY IRRIGATIONV
Tract
No.
Field
No.
Soil Type
Crop
Application
Rate(In/Hr)
Application
Amount(In.)
92
1
Roanoke
Fescue
0.35
0.5
92
2
Roanoke
Corn
0.35
0.5
92
2
Roanoke
Wheat
0.35
0.5
92
2
Roanoke
Soybean
0.35
0.5
92
5
Tomotley
Corn
0.35
0.5
92
5
Tomotley
Wheat
0.35
0.5
92
5
Tomotley
Soybean
0.35
0.5
92
4,7,8
Altavista
Corn
0.5
0.5
92
4,7,8
Altavista
Cotton
0.5
0.5
92
4,7,8
Altavista
Wheat
0.5
0.5
92
4,7,8
Altavista
Soybean
1 0.5
0.5
21Irrigation System Design must be attached.
WUP - 4

WASTE DISPOSAL SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff, drift,
manmade conveyances, direct application, or direct discharge during operation or
land application. Any discharge of waste which reaches surface water is
prohibited.
2. The Field Office must have documentation in the design folder that the
producer either owns or has long term access to adequate land on which to
properly apply the waste. If the producer does not own adequate land to properly
dispose of waste, he shall provide NRCS with a copy of a written agreement
(sample Enclosed) with a landowner who is within a reasonable proximity, allowing
him/her the use of the land for waste application for the life expectancy of the
production facility. It is the responsibility of the owner of the facility to secure an
update of the Waste Utilization Plan when there is a change in the operation, ,
increase in the number of animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for
realistic crop yields based on soil type, available moisture, historical data, climate
conditions, and level of management, unless there are regulations that restrict the
rate of application for other nutrients.
4. Animal waste shall be applied on land eroding less than 5 tons per acre per
year. Waste may be applied to land that is eroding at more than 5 tons but less
than 10 tons per acre per year providing grass filter strips are installed where runoff
leaves the field. (See FOTG Standard 393 - Filter Strips)
5. Odors can be reduced be injecting the waste or disking after waste application.
Waste should not be applied when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil
incorporated on conventionally tilled cropland. When applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not
occur during a season prone to flooding. (See "Weather and Climate in North
Carolina" in the Technical Reference - Environment file for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate
such runoff does not occur offsite or to surface waters and in a method which does
not cause drift from the site during application. No ponding should occur in order
to control conditions conducive to odor or flies and provide uniformity of
application.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or if
the soil surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that
the crop is not covered with waste to depth that would prohibit growth. The
potential for salt damage from animal waste should also be considered.
WASTE DISPOSAL SPECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on
WUP - 5

SIY9!
soils with high potential for leaching. Waste nutrient loading rates on these soils
should be held to a minimum and a suitable winter cover crop planted to take up
released nutrients. Waste shall not be applied more than 30 days prior to planting
of a crop or forages breaking dormancy.
1 1 . Any new swine facility sited on or after October 1, 1995 shall comply with the
following: The outer perimeter of the land area onto which waste is applied from a
lagoon that is a component of a swine farm shall be at least 50 feet from any
residential property boundary and from any perennial stream or river other than an
irrigation ditch or canal. Animal waste other than swine waste from facilities sited
on or after October 1, 1995, shall not be applied closer than 25 feet to surface
water. This distance may be reduced for waters that are not perennial provided
adequate vegetative filter strips are present. (See Standard 393 - Filter Strips.)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than
those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and public right-
of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways or
wetlands by a discharge or by overspraying. Animal waste may be applied to prior
converted wetlands provided they have been approved as a land application site by
a "technical specialist". Animal waste applied on grassed waterways shall be at
agronomic rates provided the application causes no runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets,
sinks, etc., shall not be discharged into the animal waste management system.
17. A protective cover of appropriate vegetation will be established on all disturbed
areas (lagoon embankments, berms, pipe runs, etc.). If needed, special vegetation
shall be provided for these areas and shall be fenced, as necessary, to protect the
vegetation. Vegetation such as trees, shrubs, and other woody species, etc., are
limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Lagoon berms and structures should be inspected regularly for
evidence of erosion, leakage, or discharge.
18. If animal production at the facility is to be suspended or terminated, the owner
is responsible for obtaining and implementing a "closure plan" which will eliminate
the possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a
regular basis to prevent breakdowns, leaks, and spills. A regular maintenance
checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other
crops for direct human consumption. However, if animal waste is used on crops for
direct human consumption it should only be applied preplant with no further
applications of animal waste during the crop season.
WUP - 6

21. Highly visible permanent markers shall be installed to mark the top and bottom
elevations of the temporary storage (pumping volume) of all waste treatment
lagoons. Pumping shall be managed to maintain the liquid level between the
markers. A marker will be required to mark the maximum storage volume for waste
storage ponds.
22. Soil tests shall be made every two years and a liquid waste analysis be taken at
least twice each year consistent with waste utilization plan. Poultry litter shall be
tested prior to application. Soil and waste analysis records shall be kept for five
years.
23. Dead animals will be disposed of in a manner that meets NC regulations.
Your facility is designed for _120_ days of temporary storage and
should have the temporary storage removed on the average every _4_
months. In no instance should the volume of waste being stored in
your structure exceed Elevation 50.6
Call the Natural Resources Conservation Service or Soil and Water
Conservation District office after you receive the waste analysis
report to obtain assistance in determining the amount per acre to
apply and the application rate prior to applying the waste.
NOTE: Sludge disposal is an item. that will need to be
addressed every 5-7 years. Your facility will provide
approximately 562 pounds of plant available nitrogen (PAN)
per year in the sludge. If you remove the sludge every 5
years, you will have approximately 2810 pounds of PAN to
utilize. If you apply the sludge to corn at the rate of 125
pounds of nitrogen per acre, you will need 22.5 acres of
land. Please be aware these are only estimates of the PAN
and acres needed. Actual application rates will be based on
a waste analysis of the sludge after the sludge has been
agitated, and the realistic yeild expectations (RYE) of the
host crop.
Narrative of Operation:
_This Waste Utilization Plan (WUP) has been amended to reflect the
crop rotations used by this operation. Table 1 shows the recieving
crops and computations. This will allow the producer more flexibility
in managing the wastes produced, and provide an opportunity for crop
rotations. The acreage shown in Table 1 represent the minimum wetted
acres needed for each crop. Field 1 is Fescue pasture and is being
grazed. The wheat/soybean rotation will be a double crop with the
wheat being harvested. The Soybean RYE has been reduced to allow for
application on the wheat. Any crop rotation following Soybeans will
have the pounds of nitrogen (N) reduced by 20 pounds to account for
the N residue from the Soybeans. When the cotton rotation is used,
wheat will be overseeded (-) to allow a fall application. The wheat
will not be harvested and the pounds N per acre has been reduced to
reflect this. These rotations or combination of rotations along with
WUP - 7

5/2195
.i....i`TI1L�1�!if��������_
Your facility is desigi-led fo, _%2U dray::; of tempt:,1'-ar-y stcartacle rand
,t
ahlr.:Ul.d hl£:1VC? thC? te(T1p(l1'-aV'y Stoll`"c:IgC? removf:?d orl the avei1'"cage evc.nr"y _ ^J'
Mc. rlth<.:s. Irl no ill:5tarlce shOUld the volume of waste being stored irl
yC.:,L.11'- �,t1-L.ICtU1-'e exceed E1c?vaatiorl
the Natural FiCasourC,-,e'.i cclrl.if•':?rvuati.oI"l zier"vic:E.? or foil i:arld Water
E,C�I'laC?4'Vr".:It].C1rl District efface after- you receive the waste arralysi.s
reI:]ort to obtairl i:as.';ista1'lce il'1 deter"frliI'1:iI'1g the citrli,l..l1'l{; per eacr'.C? to
apply raved the applic:ati.orl rate pricer to applyirig the waste.
i`Jl: "rE:_ The Waste Utili aati011 Flan MUSt corltairi orcvi,ions for
I]C?r"iodic Ianci eapp1..ic_ration 0f slL.ldCle at aqr"QYIC-mic rates. T1•'Ie
sludge will be rll.Atrieyit rich raved will require precautiorlaary^
il'1C?Gatil.lres to 01 event over iau)Ll.l Ic:ation of n(..Itr".lC?rt'I s, oI-- o t I -i a I-
e I e m 011tS
Narrrativea of Operation:
----------------------------------------------------------------------
WASTE UTILIZATION PLAN AGREEMENT
:I MEF) urlder•staarld, Will i.rrlpleinerlt arid follow the specificatiovi s �illci
t;hV I—c•1t;iC}Y'1 e:l1'1d illrili.rlterlit1.1c:a F;11"'C.:tcc?duI"'aEEr eatablished i1'1 t:h'1C? clpFaI"c.VC:d
ra1'liIII al. w'C.Xste utili::aticm plaarl for the Farm reamed above. I (We) 4CIlC�W
j.11.1y C:?.:15carl_:>i. rl to t;Flr, e::irstirlg design capacity of t;he: was,stf.
1-'re<atmc?vd; .71'ld/or storage sy teill or col'1_-structiorl of new facilities will
1"'f''(IU'.LI CD Z VIEWJ l..l'I:i.1.`L::r":1t1.t:�1'1 pl.c:1Y'1 c iicl a r1C?4V certi.fiC::a iC)I1 tC, h]c-? _aL,1bm.-:.tLed
to DEM before the rlew animals arty stock e-d. I (WO) LAHCIOrr.,O, arld
tht:It:: 1-h-101-P MUSt hse vic, cilsi::hcarg ? of ,allirna:Il Waste fl r:m thi s. syGst�.�m
surfokc e waters; of the Mate for i.Arly I-Re-kSC"1'l C?:4cC1pt st:oral evprlt�.a as,
=nc7Jf_�1 ti! a-1::r the 25 yF?ar", 24..._hCjL.lr storm C:-r greater. The DEM 1"agL.11,:Atic.rls;
regL.lir•e ca, eOpy of thlc? approved p.laarl bc? filed ore -site at the farm
office envld nt; t;he c!ffic e of the lc}{::cal. F,ioi.l al'ld WFatf:•v CC;o1sF. rvc-atiC,vl
District avid will be .available foe- rev.i.ew by I)F, M uj:r+ rl recll.+c?st
Frailur1? tc, comply with U-ic 41as;te L.Aj.11zatic;rl plarl will rautomabic_ally
ref:{i.I.Lr c.? early cost share furldrs to be I efurlded to their sc-mir'ce.
rdrlrnE? of F ac;i,l.i. }` Clwr .4" (pl.eGa4e print)"f�f,f_._.+..��1lJ�/_...._�.__.__..__". _.....__
,11!!::..._._...---._.._.........__._...__...---•-•--...-•--•------•--•---•-•-•,..__..___•^.__ I)�a t;i? . ...,�.� ,.�..._.._.__....��-..._
t%lzIme c::,f MIGt'r1agc:3r (if different from Emner) :
`:= i':;) r1<':l i.:c.�.r"ta ^...."...._...._....____.....___......"......."._._...... ,..._.._..--�--- •--•-----�---•-•--- I)a:1 t£•? : .__._...__._.__. _.__....._......__.......
WUF' -- R

. . `
5/2/95 _
Where owners of animal opc4rat1ons do not have adequ�te amount�-; of land
to Apply the waste, the producor muSt provide a written agreement
wherci6y anothor landowner has agreed to land apply or allow land '
,�.Application on his or her land. The attachF.@d agrRC-mC"nt may be used or
some other documentation mey be provided.
'ADJACENT LANDOWNER AGREEMENT
I, ____________________, understand that Mr./Mrs.
does not have ample 1iand to apply the animal waste produc�d from
animal operation. I agree and give permission for Mr./Mr�.
to apply anLmal waste from his Waste System on
uf my lzxnd for the duration of time shown below.
[ further that this; waste contains nitrogen, phospho`'ous,
»otas;sium, and other nutrient elements and when properly applied
�hould not harm my land or crops�. I e1so unders;tand that the use of
this will reduce my need for commercial fertilizer.
Tmrm of Agreemcnt: , 19__ to
(Minimvm of Ten Years on Cost Shared Items)
(See Specification No. 2)
Recipient Landowner (please print):
ture: Date:
�
PLAN APPROVAL.
Ncum o of Technical Specialist: (Please print):
�
rlffiliation (Agancy):
Signature:
SWCD BOARD REVIEW
SWCD Represontative (please Print):
`
WUP - 9

-� iN al�li/� � 61�6i

Ir Tic.
1;1: �* 47
A
:till"ell"t. t

NOS l � fr �! Pa•.yl>.9 i i � tE.�`��� fiill�l�b�• .� � .. ,.
k ! •d }���� kpt s�••, �,� �.. `,� ,.� Ire ���
7,77
27k. V.
x,.1, 1 `w' !�. 11 'C•V � ° +�, �' ` A �1�+, 15 �ri� t \'��r� � ,\p° , ``�.
MIJ, k 01
LO ` 4,
k
f�

STATES DEPARTMENT OF AGRICULTURE
\L RESOURCES CONSERVATION SERVICE GATES COUNTY, NC
SOIL LEGEND
Map unit symbols and names are alphabetical. Map symbols ore letters or a combination of
letters and numbers. The first letter Is capilalized and Is the first letter of the series for higher
level of classification) name. The second letlei is Iowarcase. The third letter Is capilalized
and denotes the slope phase. Symbols with only two letters indicate soils that are named at a
category above the series level.
SYMBOL
NAME
AaB
Alaga sand. 0 to 5 percent slopes
AIA
Altavista fine sandy loam, 0 to 3 percent slopes
BaA
Ballahack loam, 0 to 2 percent slopes, occasionally flooded
BeA
Belhaven muck, 0 to 2 percent slopes
BnA
Bladen loam, 0 to 2 percent slopes
BOB
Bonneau loamy fine sand, 0 to 6 percent slopes
CIA
Cape Fear loam, 0 to 2 percent slopes
ChA
Chowan loam, 0 to 2 percent slopes, frequently flooded
Cos
Coneloe fine sand, 0 to 5 percent slopes
CrA
Craven line sandy loam, 0 to 1 percent slopes
CrB
Cravan line sandy loam, 1 to 4 percent slopes
CrC
Craven line sandy foam, 4 to 8 percent slopes
DoA
Dorovan mucky peat, 0 to 2 percent slopes, frequently flooded
ExA
Exum sill loam, 0 10 2 percent scopes
GOA
Goldsboro fine sandy loam, 0 to 3 percent slopes
IcA
learia tine sandy loam, 0 to 2 percent slopes
LeA
Lenoir loam, 0 to 2 percent slopes
LOA
Leon sand, 0 to 2 percent slopes
LyA
Lynchburg fine sandy loam, 0 to 2 portent slopes
NaA
Nawney loam, 0 to 2 percent slopes, frequently flooded
NoA
Noboco fine sandy loam, 0 to 2 percent slopes
NoB
Noboco fine sandy loam, 2 to 6 percent slopes
PaA
Pactolus sand, 0 to 3 percent slopes
PnA
Pantego fine sandy loam, 0 to 2 percent slopes
PuA
Pungo muck, 0 to 2 percent slopes
RaA
Rains fine sandy loam, 0 to 2 percent slopes
RoA
Roanoke loam, 0 to 2 percent slopes
SIA
State line sandy loam, 0 to 2 percent slopes
SIB
State line sandy loam, 2 10 6 percent slopes
TaA
tomahawk line sand, 0 to 3 percent slopes
ToA
Tomolley fine sandy loam, 0 to 2 percent slopes
Lid
Udarthents, loamy
VaB
Valhalla fine sand, 0 to 6 percent slopes
Writ)
Winton line sandy loam, 8 la 15 percent Slopes
Wn1=
Winton fine sandy loam, 15 to 30 percent slopes

ATTACHMENT B
No l't h Ca!- o 1 011 ,. .4 : s., it i t :l ''.►l l: ,t' e'f , , o •f
Agr. i--Waste Man -a emen-t
g
Biological and Agricultural Engineering - North Carolina State University
LIVESTOCK VASTE SAMPLING. ANALYSIS AND CALCULATION
OF LAND APPLICATION PATES
James C. barker*
1. SAMPLE COLLECTION
A. Semi -Solid Lot Manure
L. Scraped directly from lot into spreader
a. From loaded spreader. collect about 2 lbs of manure from
different locations using nonmetallic collectors.
ii. From storage
a. Collect About 2 lbs of manure from under the surface crust
avoiding bedding materials and using nonmetallic collectors.
B. Liquid Manure Slurry
I. Under -slotted -floor pit
a. Extend a 1/20,nonmetallic conduit open on both ends into
manure to pit floor.
b. Seal upper end of conduit (e.g,._by placing a thumb over end
of conduit) trapping manure that has entered lower and, remove
and empty slurry. into plastic bucket our nonmetallic container.
c. Take subsamples from'S or more locations or at least 1 quart.
d. Mix and add about 3/4 pint to nonmetallic sample 'container.
ii. Exterior storage basin or tank
ar Make sure manure has been well mixed with a liquid manure
chopper -agitator pump''or propeller agitator.
b, Take subsamplis from about S pit locations, from agitator pump
or from manure spreader and place in a plastic bucket.
* Professor and Extension Specialist. Biological and Agricultural Engineering
Department, North Carolina State University. Raleigh, !;C.
1 of 3

ATTACHMENT B
2 of 3
e. Mix and add 3/4 pint to a honmietallic sample container,
C. Lagoon Liquid
I. Collect about 3/4 pint of recycled lagoon liquid from inflow pipe
to flush tanks in a nonmetallic sample container.
it. From lagoon
a. Place a small bottle (1/2 pint or less) on end of 10-15' pole.
b. Extend bottle 10-13' away from bank edge.
c. Brush away floating scum or debris.
d. Submerge bottle within 1' of liquid surface,
e. Empty into a plastic bucket, repeat about 5 times around
lagoon, mix, and add 3/4 pint to nonmetallic sample container.
R. Broiler or Turkey Litter
I. House litter
a. Visually inspect litter for areas of varying quality, e.g..
areas around feeders and waterers, and estLmace percent of
floor surface in each area.
b. Take about 5 litter subsamples at locations proportionate to
Item a. E.g., if 201 of litter of similar visual quality is
around feeders and waterers, take 1 subsample there and the
other 4 subsamples from remainder of floor surface.
e. At each location, collect litter from a 6" by 6" area down to
earth floor and place in a plastic bucket.
d. After 5 subsample■ have been added to the bucket. mix. and add
about-2-3 lbs litter to A nonmetallic sample container such as
a 1•gallon (rester bag and seat.
it. From stockpile
a. Take subsamples from about 5 locations at least 18^ into pile.
b. Rix. add 2.3 lbs to nonmetallic sample container and seal,

,r
i
ArrACITHEUT H
3 of 3
II. SAMPLE PREPARATION AND TRANSFER
A. Place sample into an expandable container that can be sealed. Rinse
residues from container with clean water but do not use disinfectants,
soaps, or treat in any other way.
B. Pack sample in ice, refrigerate, freeze, or transfer to lab quickly.
C. Hand -delivery is most reliable way of sample transfer.
D. If mailed, protect sample container with packing material such as
newspaper, box or package with wrapping paper, and tape.
E. Commercial sample containers and mailers are also available. Contacts:
i. AFL Eastern Agricultural Lab, Inc. III. Polyfoam Packers Corp.
7621 Whitepine Road 2320 S. Foster Avenue
Richmond, VA 23237 Wheeling, IL 60090
Ph: [phone] Ph: [phone]
ii. Fisher Scientific Co. iv. NASCO
3315 Winton Road 901 Jonesville Avenue
Raleigh, NC 27604 Fort Atkinson, WI 53538
Ph: [phone] Ph: [phone]
F. Private analytical labs are available, but sample analyses are costly.
C. The NCDA provides this service for North Carolina residents.
1. Address: North Carolina Department of Agriculture
Agronomic Division
Plant/Waste/Solution Advisory Section
Blue Ridge Road Center
P.O. Box 27647
Raleigh, NC 27611
Ph: [phone]
Attn: Dr. Ray Campbell
ii. forward $4 along with the sample.
Iii. Include the following identification information with sample:
a. Livestock species (dairy, swine, turkey, etc.)
b. Livestock usage (swine -nursery, finishing; turkey -breeders,
brooderhouse, grower, number flocks grown on litter; etc.)
c. Waste type (dairy -lot -scraped manure, liquid slurry; swine -pit
slurry, lagoon liquid, sludge; broiler -house litter, stockpile
iv. Routine analyses performed on all samples: N, P. K, Co, Mg, Na,
S, Fe, Mn. Zn, Cu. 8
v. Additional analyses performed upon request: DM, Mo, Cd, Ni, Pb

a
.D 14.114e&V&7 97
71
.00,7
S'MOS'
oe
070e
T6O'el
O_f7:p
0/ 4",f1tWV27171 5.469.4pOe V
j, fl, S V? k. f[ Ll kli E.-) 6 V ut u v,"j. k.,k F»" w k.k C) tl: A (J
.11,1:3 LIOTSTAT�-j "'11- V'?N PU%-?
,1 0 L I _J. •s e v, q S f a f[ u 1--1 a q ? j,,:) 15-1E-3'-}IPM Q-1LA1 H, --I. L.1 1�! 1 :1
s -r F.D' a k I.J. _J. LC 1:1 Ll 0 A Cl
-6 T (j 1.
El a t1i T �J. e �j V� '� L"D T-1 Z3 L. 'I '� f--1 0 - t �',) A 1.) a Cl
(.I Z3 I i3 k4 1. Lt Q 0 C-) I? H Ll .1. h U I.: k 3 L i C-) i.J
:3 YI C] JL'j
T r 4 [.1 1 D Ul -.1. J. C) LA Q V? A Ll a U CI 0 CI. 16 &) l [.:) E-3 (-I tJ -E b A V? t,l E-) I E,.,
f yj f.)
-.i3.A Cl E-a Ct U Q C) t.*) V? I f[ L. I e.'-) U J 1. V- E.) 1 .1 E3 Ll -1 4 L.1 -j p a p ul a Lu LA) o :) ED -1 A (At c-) I I
.,.1 1::) n [:) L.U.) M Uj C) D a 1 0 .1 Cl 'I.: S l.:.i
A'[Cj�?UC)SV--!DJ SV� 1.) B I dv !:.� -1 a. .1 �� v.? m El L. F.'.) 'I: t:.
.') 4
A e -I u k..l e a J'.) e w ,,) c I n ::) t. Is 1.1 o 'L -.1 1: --a -c 'L d d e ..I o P a k e a Ll J. Q .1 S L
-1A.1 Lka I -A.-} ViLA S- B U T W J 0 E-) 1) 1.) '.1. Ej I DA D LA Cj I Cj r-? T I CA d Y? t I D V-? F-) ..A oj C1.
t., I Y:.' i�,) cl p ri cj k. 1 s T v? -t a ,I. v? u) �--1 .1 s 0 m a q Uk 1:3 '1 V-,� -I.: r. cli cl e p u Y.,! -1- 63 A 'D .4 CI
t. E3 .1 Ea 1? t -.1 j C) U f I vi a raUle faU T I' C W -E? S
PE3MO t 1 01 Dfl P 10 Q k-4 L t IE? 'I d q. t. L a w a T-- ti e ui i:..) I S I? M [) i--3 L4 '-') f? 1. -.11? ED k
Lt C.) I.: .}V?Ac3 I E-.3 k
Cl -D.� Cj -5-LEJ:�JAV2W I, I..k a t.i e ej -i a c-I A q p a -.-,I i LO S 10-T LA 0 '1 'V F A a T E) e
A F1 ,:)be6 LjJ. 'D Yl 0 C.1 W V) C.l U 1 f.5 F, Lj --[ (A I.-,) to A -.k
I. t m i o ;1, a , t a k..j .1 c.-3 b e 4oqf"5 a
(-)B'r k 0 J. [i B U 6 'K S:: f) 5 T A I. L - E? j 4,111.) LA ::) 1.: 4 F.-'.'J V? A rl it S SF i?:) X C-3
-3 UJAIDJ.!.'� Al-IlDLI -JkN.)A gp U T U I k I Q .. t JL) LA P � .1. Lt a A L T TV? I. U I k-? -k
j "D Q E-) U) 1 1.) A c:F L.1 fI J C),
V.., I.: LA Q 'D f".') Y�, Z:,) t o L 1 C') il: tc)(J A t ,..1':a
4 L I I.") T f.-3 M E3 A B .1 V? -q. E.--, APY�B4S J-0 P,11-10d J E) d C) 04 D -C cl Y-1
i.-
'MAID J.C� S. 1:..) 1") 'r. i 't . A ID M LA T u
Oft t E.) A Q k,.kc.)(,.j Clfj 0 U E: A C) E_
a b e ...i o.j s A k e -.t o d to o 1. -jk..lE3kAV?W (8 d q q q t.5 tj k u'!
E:j P W I L.t):? / t:� �j f:)
I..t oo t.-� -e C.) t I . ( ,:):'I. ;k- . f. c
[ V'% ',1 0 .1 V? A 0j. p ut i.: e 61 -n v? J. u I 1::"A.
Lk 0 1 "1. 1.? J ED (A t) . �.(

l0/93
Producer: _ 4� ------------
The purpose of this plan is to provide guidelines for carrying out
the routine operation and maintenance work needed to keep this swine
waste management system functioning as planned. Routine maintenance
is considered to be normal good care of the system. Good
maintenance adds to beauty, usefulness, and permanence.
A. Maintenance
The routine maintenance of the lagoon involves the following:
1. Maintenance of a vegetative cover on the embankment top and
side slopes: ____ ______________ is
being established on these areas'. Beginning in 19pg and
each year thereafter, the embankment should be fertilized
with 800 pounds of 10-10-10 per acre to maintain a vigorous
stand.
H. Control of brush and trees on the embankment' This may be
done by mowing, spraying, or chopping, or a combination of
all three. This will need to be done at least once each
year and poshibly twice in years favorable to heavy growth
of vegetation'
Maintenance inspections of the lagoon shnuId be made during the
initial filling of the lagoon and at least annually. Items to
be checked should include, as a minimum, the following:
1. Waste Inlet Pipos, Overflow Pipes
a. condition of pipes
( I ) separation of joints
(2) cracks or breaks,
H. Pool Area
a. undesirable vegetative growth
b. floating or lodged debri�;
3. Embankment
a. settlement, cracking or "jug" holes
b. side slope stability - slumps or bulges
E. erosion and rodent damage
A. Transfer Pump

91
ENIERGENCY ACTION PLAN
PHONE NUINLBERS
DWQ
EMERGENCY il�,L-iIAGE.%IEvT SYSTEL1 __ 911
SWCD. 919- JS7 1991
N-RCS 9iq- JS7- 1881
This plan will be implemented in the event that wastes from your operation are leaking, :
overflowing, or running off site. You should not wait until wastes reach surface waters or
leave your property to consider that you have a problem: You should make every effort to
ensure that this does not happen. This plan should be posted in an accessible location for
all employees at the facility. The following are some action items you should take.
1. Stop the release of wastes. Depending on the situation. this may or may not be
possible. Suggested responses to some possible problems are listed below.
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable. rate.
c. Stop all flows to the lagoon immediately.
d. CaIl a pumping contractor.
e. Make sure no surface water is entering lagoon.
B: Runoff from waste application field -actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and elirtvnate the reason(s) that caused the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Close vallves to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
D: Leaka,e from flush systems. houses. solid separators -action include:
a. Stop ,recycle pump.
b. Stop irri;aticn pump.
c. Make sure no siplion occurs.
d. Stop ail tlow.i in the house. tlu>h systems. or scild separators,

e. Repair all leaks prior to restarting pumps.
E: Leakage from base or sidewall of Iagoon. Often this is seepage as opposed to
flowing leaks- possible action:
a. Die a small sump or ditch away from the embankment to catch all seepage,
put in a submersible pump, and pump back to lagoon.
b. If holes are caused by burrowing animals. trap or remove animals and ftil
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon
bottom as soon as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much .was released and for what duration?
c. Anv damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f.. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off of the property)?
h. How much reached surface waters?
3: Contact appropriate agencies.
a. During normal business hours call your DWQ (Division of Water Quality)
regional office; Phone"50 141 After hours, emergency number: 919-733-3942.
Your phone call should include: your name, facility, telephone number, the details
of the incident from item 2 above, the exact location of the facility, the location or
direction of movement of the spill, weather and wind conditions. The corrective
measures that have been under taken, and the seriousness of the situation.
b. If spill leaves property or enters surface waters, call local EMS Phone number
C. Instruct EINS to contact local Health Department.
d. Contact CES, phone numbed /?,OjV 0 local SWCD office phone number - -
and local NRCS office for advice/technical assistance phone numberO?�f'f? "-F91
4: If none of the above works call 911 or the Sheriffs Department and explain your
problem to them and ask that person to contact the proper agencies for you.
5: Contact the contractor of your choice to begin repair of problem to minimize off -site
g
damae.
a. Contractors tame: 1COBFJ�T C/i�,csoN
b. Contractors .-address: Jreu C
c. Contractors Phone:
I ,>. 1996

b: Contact the technical specialist who certified the lagoon (NRCS, Consulting
Engineer. etc.)
a. Name: 161041AS T'
T Implement procedures as advised by DWQ and technical assistance agencies to
rectify the damage. repair the system, and reassess the waste management plan to
keep problems with release of wastes from happening again.
Dc.emrer 1 `%. 1996

Mortality Management Ni lethods
(check which method(s) are being implemented)
Burial three feet beneath the surface of the °round within 24 hours after
knowledge of the death. The burial must be at least 300 feet from any flowing
stream or public body of water.
CI Renderine at a rendering plant licensed under G.S.- 106-163.7
❑ Complete incineration
❑ In the case of dead poultry only. placing in a disposal pit of a size and design
approved by the Department of Agriculture
❑ Anv method which in the professional opinion of the State Veterinarian would
make possible the salvage of part of a dead animal's value without endangering
human or animal health. (Written approval of the State Veterinarian must be
attached)
I
C'e.: tuber IS. 1996

Swine Farm Waste Management Odor Control Checklist
Source Cause BMps to Minimize Odor Site Specific Praclices
F:,ntutca,l Swine production 17 Vegetative, or wooded buffers; '
O Recommended best management practices;
NK"Good judgment and common sense
Auintal body surfaces • Dirty manure -covered aniutals WDry floors
l lour surfaces0 Wet manure -covered floors Slotted floors;
COY Waterers located over slotted floors;
GY"Feeders at high end of solid floors;
0 Scrape manure buildup from floors;
e Underfloor ventilation for drying
Mau„rc collectiuu pits firing; 0 Frequent ivanure removal by flush, pit recharge,
• I'artial microbial decomposition orscrdp?e;'
❑ Underfloor ventilation
Walil.,tiun C."hawa fans Volatile gases; Fall tnaintertance;
Dust 0 Efficientair ralovernent
111tiuor surface 0 Dust Washdown between groups of animals;
0 freed additives;
l�l+up, taul.a
❑ Feeler covers; -
da Feed delivery downspout cxteude n te, fcedcr
covers
ion of recycled lagoan f] Fluilt Heil; covers;
liquid while tanks are filling 0 Exlend fill lines to near bottotn of tanks with
anti -siphon vents
Flusli allrys • Agitation during waste%vatcr Underfloor flush Willi underfloor vettilatiou
canvcyatacc
]'it itcbaiLc paints 0 Agitation afrgcycicd lagoosi ❑ Extend rccleargc lines lu near bolloui ol•pils
liquid while pits arc filling Willi anti -siphon vents
Litt stations 0 Agitation during sump tank O Sump lank covers
filling and drawdown
Outsido drain colicctiun • Agitation.duriaag waslcwalcr © 1301 covers
Or juuttion I,nsCs Coavcyataee :
A NIOC - November I l, 1996. Page 3

Source Clause IMPS to Minimize Odor Site Specific Prrcliecs
End of drainpipes at * Agitation during wastewater ❑ Extend discharge point of pipes underneath
lagoon conveyance lagoon liquid level .
Lagoon surfaces * Volatile gas emissions; 610'—Proper lagoon liquid rapacity;
* Biological mixing; ❑ Correct lagoon startup procedures;
* Agitation O Minimum surface area -to -volume ratio;
Cl Minimum agitation when.pumping;
❑ Mechanical aeration;
O Proven biological additives
Irrigatiolt sprilakler * 1ligh pressure asilatiorr; Irrigate on dry days with little or no wind;
1104 ICS * Wind drift
fiet"'Minimurn recommended operating pressure;
N" Pump intake near lagoon liquid surface;
Gd"Pump from second -stage lagoon
St(iraLe talik ur hasiu * Pailial microbial decomposition; M Haltom or midlevel loading;
ball trace 0 Mixing while filling; IT Tank covers;
* Agitation when emptying ❑ - Bashi surface mats of solids;
Cl Proven biological additives or oxidants
Settling basin surface *
Partial tnierubial decomposition;
(]
Extend drainpipe outlets underneath liquid
*
Mixing while filling;
level;
*
Agitation when emptying
Cl
Remove settled solids regularly
Manure, shiny or sludge *
Agitation when spreading;
❑
Soil injection of slurry/sludges;
spreader oulluts *
Volatile gas emissions
❑
Wash residual manure from spreader after use;
C3.
Proven biological additives or oxidants
Uncovered manurc, *
Volatile gas emissions while
IT
Soil injection of slurry/studges
Shiny or sludge on field
drying
❑
Soil incorporation within 48 hrs.;
surfaces
❑
Spread in thin uniform layers for rapid drying;
❑
Proven biological additives or oxidwas
Dead auiruals *
Carcass decomposition
W
Proper disposition of carcasses
Dead anitual disposal *
Carcass decomposition
❑
Complete covering of carcasses in burial pits;
pits
O
'Proper location/constnaction ordisposai pits
InLllleliItlla5 *
Incuulplete culubusrion
❑
Secondary stack buneus -
AMOC C11111CF 11. 1996, Page 4

' - 1
Suurcc Cause BMPs to Minimize Odor Site Specific Practices _
Stauding water around • Improper drainage; Grade and landscape such that water drains '
facilities . Microbial decomposition of away from facilities -
organic matter
hhuture tracked onto • Poorly maintained access roads E3 Farm access road maintenance
public roads tram farm
access
Additional Information: - Available From :
Swine Manure Managemettt ; 0200 RuldBMP Packet NCSI1, County Extension Center
Swine Production Farm Potential Odor Sources and Remedies; EBAE Fact Sheet NCSU - BAE
Swine Pruduction Facility Manure Management: Pit Recilarge - Lagoon Treatment ; EBAE 129-98 NCSU - BAEi,
Swine Production Facility lvtanure Management: Underfloor Flush - Lagoon Treatment ; EBAE 129-99 NCSU - BAF
Lagoon Design and Management for Livestock Manure Treatment and Storage; EBAE 103-83 NCSI I - BAk
Cuiibrnion of Manure and Wastewater Application Equipment; EBAE Fact Sheet NC SI J - (IA E
C'uutiullitig Odors frum Swine Buildings; 11111-33 NCSU - Swine Extension
L_uvirunmental ASSnrance Program ; NPF'C Manual NC [lurk t'ruducers Assoc
Options tar Managing Odor ; a report frorn the Swine Odor Task Force NCSU Agri Communications
Nuisance Concerns in Animal Manure Management: Odors and Flies; ; PRO107, 1995 Conference Proceedings Florida C:oaperwive Extension
AMr rr: - rJvrveml,cr l 1, 1990, PaCC 5

Insect Control Checklist for Animal Operations
Source Chute BMPs to Control Insects Site Sl►ecific Practices
Liquid Systems
Flush Gutters Accumulation of solids Flush system is designed and operated '
sufficiently to remove accumulated solids from
gutters as designed.
O Remove bridging of accumulated solids at
discharge
t_agu►►us and fits Crusted Solids Maintain lagoons, settling basins and pits where
pest breeding is apparent to minimize the
crusting of solids to a depth of no more titan G -
8 inches over more than 30% of surface.
Excessive Vcgulalivc • Decaying vegetation 1s71' Maintain vegetative control along banks of
�ru►vd► lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along walees edge on inipotiodmenl's perimeter.
_ my Systems - —
I cc.tce� Fecel Spillage n llesigM, operalc auil mailitain feed syslents (e.g,
bunlcrs and troughs) to minimize the
accumulation of decaying wastage.
O Clean up spillage on a routine basis (e.g., 7 - 10
day interval during summer; 15-30 day interval
during winter).
Deed sim-age Accumulation of feed residues (-1 Reduce moisture accumulation wilhln and
around immediulc perimeter of Iced storage
areas by insuring diainage away fiom silo
and/or providing adequate containment (e.g.,
covered bin for brewer's grain and similar high
moisture grain products).
n inspect fur and remove; or break up accumieLued
solids in filler strips around feed storage as
needed. _
AMIC - November 11, 1996, Page I

Source Cause
Aninial I folding Areas a Accumulations of animal wastes 13
and fired wastage
0
Dry Manure I Iandiing a - Accumulations of animal wastes 13
Systems
O
C7
BMPs to Control }insects Site Specific Practices
Eliminate low areas that trap moisture along
fences and other locations where waste
accumulates and disturbance by animals is
minimal.
Maintain fence rows and filter strips around
animal holding areas 10 minimize
accumulations of wastes (i.e., inspect for and
remove or break up accumulated solids as
needed).
Remove spillage on a routine basis (e.g., 7 - 10
day interval during summer; 15-30 day interval
during winter) where manure is loaded for land
application or disposal.
Provide for adequate drainage around manttre
stockpiles.
Inspect for and remove or lireak up accumulated
wastes in filter strips around stockpiles and
manure handling areas as needed.
For more inlOnuatian contact the Cooperative Extension Service, Department of Entomology, Box 7613, North Carolina State University,
Raleigh, NC, 27695-7613.
Ahilt : - ihrr 11. 1996, Pagc 2

2/12/96
FIN-
Producer:PA iJ L. L 1U. E Y
©/ 1. Scaled drawing of the proposed irrigation system including
hydrant locations, travel lanes, pipeline routes, thrust
block locations and buffer areas where applicable.
2. Itemized quote from irrigation dealer.
3. Waste Utilization Plan and maps.
4. Manufacturer's specifications for the irrigation pump,
traveler and sprinkler(s).
5. Manufacturer's materials and installation specifications for
the pipe and/or USDA-NRCS standard for Irrigation Water
Conveyance, N.C. Field -office Technical Guide, Section IV,
Practice Code 430-DD.
6. Irrigation System Design Parameters Worksheet to be filled
out in its entirety.
Table 1 - Field Specifications (to be filled out by Field
Office personnel)
Table 2 - Traveling Irrigation Gun Settings
• Spacing of hydrants should be computed as 70% - 75% of the
wetted diameter. For normal wind conditions above 5 mph,
spacing of 50% to 55%.should be used.
U,,-Irrigation dealer to provide sources and/or calculations
used for determining application rates.
Traveler Application Rate computed as: -
I = [ (96.3 x q) / (3.14 x (0.9 x r) 2 )] x 360/w
where,
I = approximate actual application rate (iph)
q = discharge (gpm)
r = wetted radius (ft)
w = portion of circle receiving water (degrees)
Total application amount for the given travel speed and
lane spacing should be below the maximum allowable
application amount for the crop and soil type shown in the
Sprinkler Irrigation Guide and under the maximum allowable
nutrients to be applied.

Application Amount computed as:
d = [1-605 x q]/[1 x s]
where,
d = gross application (in)
q = sprinkler discharge (gpm)
1 = travel lane spacing (ft)
s = travel speed (fpm)
Table 3 - Solid Set Irrigation Gun Settings
Spacing of risers along the main and lateral lines should
be computed as 60% of the wetted diameter.
Irrigation dealer to provide sources and/or calculations
used for determining application rates
Solid Set application rate computed as:
I = (96.3 x q]/[sl x sm] x 360/w
I = average application rate (iph)
q = sprinkler discharge (gpm)
sl = spacing of sprinklers along the laterals (ft)
sm = spacing of sprinklers along the mainline (ft)
Q Total application amount for the given operating
time should be below the maximum allowable
application amount for the crop and soil type as
shown in the Sprinkler Irrigation Guide.
Computations used to determine the size of thrust blocks
and illustrations of all thrust block configurations
required in the system.
Thrust blocks sized according to:
Thrust block area (ft 2)= W = Thrust
F Soil bearing strength
Soil bearing strength of 1200 - 2000 psf should be used.
r, Computations used to determine all mainline and lateral
pipeline sizes. Maximum flow velocity must be kept below
5 fps.

Velocity in a pipeline calculated by:
v = [0.408 x q]/d2
where,
v = velocity of water (fps)
q = flow rate (gpm)
d = inside diameter of pipe (in.)
Assumptions and computations for determining total dynamic
head and horsepower requirements. Charts may be used for
head loss in pipelines, etc. but the charts should be
included in the packet. The dynamic head-(TDH) should
include as a minimum the following components:
- elevation difference from waste water to nozzle
- friction loss in pump
- friction loss in pipeline
- friction loss from fittings and misc.
- sprinkler discharge pressure
Required system operating pressure must be less than the
available working pressure.. One foot of water is equivalent
to a pressure of 0.433 pounds per square inch. The pump
performance curve must -meet the design requirements for Q
(total for all sprinklers to be run at one time), TDH, and
BHP.
Brake horsepower computed as :
BHP = [ Q k TDH]/[3950 x Ep]
where,
BHP = power required to drive the pump (hp)
Q = flow rate (gpm)
TDH = total head the pump operates against (ft)
Ep = pump efficiency (decimal form)
✓!�. Narrative of system operation to include start-up, shut -down,
and winterization procedures and regular maintenance of all
equipment.
Waste Utilization Plan should show all areas receiving
coverage from the irrigation system. As a minimum the
acreage shown should be the area receiving uniform coverage
under the irrigation system.
Reviewed by: Date:
Approved by: �[ .I Date: 1 0

Revelle Agrl-Products
�\/Cp Soo WEST DROAD STREET PHOH[ 919•30e-3ttO .... .
--thethe way to go
MURFREESBORO. NORTH CAROLINA 27855
CHARGE TO
Paul Lilley
Rt. 2, Box 47
Gatesville, NC
27938
SHIP TO
DATE
8-2-96 Sales Code - J Traveler w Alum. Pipe
{r 1 SUBIECT TO M TAX
�J STATE TAX EXEMPT
QUANTITY
DESCRIPTION
UNIT
PRICE
AMOUNT
1
Hobbs Reel Rain, Model 1030PT
13,283.00
NC Sales Tax
80.00
13,363.00•
Ravotti PTO Pump, Model T3-80
4,332.00
1
Bauer Quick Disconnect suction kit
392.00
1
Discharge adapter
48.50
1
Suction adapter
31.60
2
6 x 6 x 6 Circle Lock Line Tees
104.00
208.00•
1
Discharge hose; 6" MCL x 4" x 6 FMCL
214.00
400'
6" Circle lock Alu. Pipe w/clamps
and Gaskets
3.35
1,327.00
6,553.10
NC Sales Tax
65.53
6,618.63
As per our agreement dated 7-22-96
This invoice is due within 10 days.
1�i% monthly service charge on past due invoices.
Total Invoice Price: - - # 19,981.63
Number

IRRIGATION PARAMETERS FOR ANIMAL WASTE MANAGEMENT SYSTEMS
Landowficr/Operator Name: af�c�C �., [., Dale: !Q
Address: _ Pf a _ f3 e X—
/ ,r, 4 7 8
Telephone: 19 4 ? 5 -7- Q 5
TABLE 1: Field Specifications'
Field
Numbers?
Approximate
Maximum
Usable Size
of Field'
(ac) I
Slope
Soil Type (°/u) I
Crop(s)
Maximum
Application
Rate
(in/hr)
Maximum
Application
per Irrigation
Cycle"
(in)
Comments
5
Tod, c/
Corn
-17
' Table to be completed in its entirety by Field Office Personnel in accordance with the Field Office Technical Guide and forwarded to the irrigation system
designer.
7 See attached map provided by the Field Office for field location(s).
' Total Field acreage minus required buffer areas. 5
Refer to North Carolina Irrigation Guide in Section 11G of the Field Office Technical Guide. Do not exceed nutrient loading rates
IRRIGATION PARAMETERS 1 USDA -NB' "
Se- ^r 25. 1995 North Cz

TABLE 2: Traveling Irrigation Gun Settings McL ON f SO &C,o S
Make, Model and Type of Equipment: 11 w
. fed � S /4307 �ec �� /�orF� � %.�- 8 D PTO Pv.,-�P � � (o Alvminv m C'C
Field No`
'1'ravct
Application
TRAVEL LANE
Wetted
Norz1e
Operating
Operating
and
SpCCd
Rate
EffeclivC E fcclive
Diameter
Diameter
Pressure
Pressure Arc
I
lhdrani Noy'
(fthnin)
(ill/ lu}
Width(ft) Length(ft)
(fl)
(in)
(ir; Gun (psi}
to Reel (psi) Pattern' Comments
s See attached map provided by the Field Office forlicld localion(s).
Show separate entries for each hydrant location in each field.
' Degree of Arc.
IRRIGATION PARAMETERS 2 USDA-NR''"
Sr• 'per 25, 1995 Notth G

TABLE 3: Solid Set Irrigation Gun Settings
Make, Model and pc of Equipment.
Field No` €ication II �dranl S chi ft Wetted
and Number of lc Along Between Diameter
Linc Ne Hydrants 0" hr Pipeline Pipelines Ul)
E L7IPMENT SETTINGS
No'r71e Operating Operating
Diametcr Pressure Time Arc
(in) fa; Gun (psi COV Hydrant (hr) Pattern" Comments
s Sec attached map prodded by the Field Office forfleld locatioq(s).
9 Show separate entries for each hydrant location in each field
1° Dcgree of Arc.
IRRIGATION PARAMETERS
Ser` -•ber 25, 1995
t
; 3 .
USDA-NRr e
North C

TABLE, 4: Irrigation Syslcm Specifications
Traveling
Irrigation Gun
Solid Set
Irrigation
Flow Rate of Sprinkler (gpm)
/9 7
Operating Pressure at Pump (psi)
Design Precipitation Rate (in/lir)
I lose Lcngth (II)
S
XXXXXXXX
Type of Speed Compensation
r j„ n r
xxxxxxxx
Pump Type (PTO, Engine, Electric)
PT()
Pump Power Requirenecnl (lip)
4 —$.
22.8
TABLE 5: Thrust Block Snecificatiod'
LOCATION
THRUST BLOCK
AREA (H4)
90° Bend
All
Dead End
A
Tee
A
Other
Other
�` u, p', ? e.
NOTE:
A buffer strip 50 feet wide or wider must be maintained between the limits of the irrigation system and all perennial streams and surface waters per
DEIINR-DEM Code, Section 15A NCAC 213 .02041- Waste Not Discharged to Surface Waters.
" See USDA-NRCS Technical Guide, Section IV, Code 430-DD.
IRRIGATION PARAMETERS 4 USDA-NRr-9
Sept—iber 25, 1995 North Cr

Narrative of Irrigation System Operation
Briefly describe operation of the system in the space provided below. Include procedures such as start-up, shut -down, winterization
and regular maintenance.
IRRIGATION PARAMETERS 5 USDA -MRCS
Ser' -ber 25, 1995 North Cr

IRRIGATION SYSTEM DESIGNER -
Name: (TIgR v AJ . MAN,v.JJG
Company: �P v1l* 44 #4 — Pruc�o e /s _
Address: _-5-dr r Ix�s f P_,rr>cv, _Z 4- _
,/ rGcSLorO A/C
Telephone: 9L=�f2 X r .w t.
REQUIRED INFORMATION
The following information and computations must accompany all irrigation designs for review:
1. A scale drawing of the proposed irrigation system which includes hydrant locations, travel lanes, pipeline routes, thrust block
locations, and buffer areas where applicable.
2. Specifications for the irrigation pump, traveler, and sprinkler(s).
3. Computations used to determine all mainline and lateral pipe sizes.
4. Total Dynamic Head computations and Horsepower requirements.
5. Sources and/or calculations used for determining application rates.
G. Computations used to determine the size of thrust blocks.
7. Manufacturer's specifications for the irrigation pipe and/or USDA-NRCS specification for Irrigation Water Conveyance, Technical
Guide, Section IV, Code 434-DD.
IRRIGATION PARAMETERS 6 USDA-NRCS
September 25, 1995 North Car -"-a

0
Narrative of Irrigation System Operation
Describe the operation of the system in the space provided
below or on a similar sheet most convenient to the
designer/supplier.
Include procedures such as start-up', shut -down, winterization
and regular maintenance of all equipment.
This irrigtor is designed to apply of water at specified
ratings. Pump should be primed and started and 1030
traveling hose should be extended to specified destinations
in accordance with map. The reel should be started in manner
that is given in owner's manual that accompanies the machine.
The machine is equipped with shutoff system,' so there is
no harm done to the machine itself. The irrigator should
only be ran in accordance with the waste management plans
and to the specifications of this design.
Winterization should be done when the machine will be shut
down for more than a month at a time, during the winter
season. All water should be drained and machine should
be greased and oiled.
Regular checks should be made on the reel, hose, and all
mechanical equipment on the machine itself.

Rf o7 Box �o
alezyirle ,/IC A7g3S 1.
�919 )` 3'T'? - a 5.7 5 .
Fie��J S _maxtI m
�.9•); w J s
0 519 7'
dcr�s Cavcr�Cl r �+—_ %rQ %r 0
% s / fa 5 9
'72G c/xw
'7 Q
SaJ.7� ,3/b,r9
_ - �..—....----�.
9a

—LLLS.
IV S
*?Oa3 //00Psz 9T L '90V
Ll
17 *7 G -
3. 8 S r K, V3 3
t

�. .
�rw0+, //^�� �� 8.00
� xo
13,
^�
� /
^
37'�
-'------------
--'------ —r'-- --------�------ ---'
^

4
10
go,
AT
. 'ej
4t'
of
-PT
Aj
INTARIS"i %1! 7

R!woman NamesmaM■EamomsammirlM■MMR mail ■■■■ !■fmR
r■son /m■! i \■■iif■!Mi■Rais■s■mmrwNNmra■ Ickmlmarr.r=+lama
/■miirr�!■■!■m■■M■mammiaa�sismEMi■aala■Mmm■R■liimi�■as
Nunn iaiiiinoun �im#iisiiii■aii■\:0 men
rai�i
11iii���iaisesisi�iiiiiiiii0i�iiiaiixwi xrmixlMiiiiHOU
iiiiinderldiisnaffs iiRi
■■p■■aarir...+���������---r���� � 111H
AWN on ovum
Mai
Room iiii�iiiiiiiaiiiiii'�ii� iisiiiiE rMUNIS iiMMIR IA,
MMfisa aissiiisiiwws■i■ r■■a* r rrm rrallaaamw�Iwr■
■ LN. ■■mfaisM filMmmasswmi
•r.
�r�1��/VIami�rli■■Ei■iRMlRm■/.am�rm
■ rrr 'arr.....e.....r&..
�E
■■RM!■■INMN>M■■R■■■!■M■■AtIRMn■■a!■r■.�=••
a■RNa■E■■■■■saa■■■!■■m/■1{aslia■.tr■■■aa■iiR
RIRfilri[ra�rr�rrrisurlra`'0,A00 on: IN IPFAi
go No
■■l■■■>Elms■mm■■!■■aak■1Room ■nomm's■mR['!R
■!ss■Naaa■aama■■■a■■
rrrrrNi///s■/N/si■s■
■a■N■ltNm/E■Rsiammamr
smrass■■ ■sMs■MMEMEM
■R■/■ssa armwI�■//liaa
■EMEMMMMMMM■RMM■■a■m
�iws■iNirrrrlrrrrrr■
Y1mma■smMs■ Msa UH:
11fm■■■■s■/�■RaAAA■!!
/Ylasr■iwEE■Mra/EMmr■
Y,EEa■■immmrmmaM■ ia■
Il��mra■aMmmsa■amaMiia
OR
0
■l's2ft�9'4aaammiYlrla■■mMmRRmR RaE
■mNo!
■!ir ■ill!�i ■f!■■imNRMI1rEMr[,■■! ■Nr�lrm!■{lrrrrrrfrimrrrim
■ M■I�■f r•rf'�msaiNaMf ■mill■■f�Mrir■lfmarrls■■mmmm■mwiaa■
��■�■■■■E�A■M!■ME■MMMMRi■aN■■■■■■�■■■!:■fM■MM■!■#A■M■aNM■
RammRlammmrimRmimmmmif.iimm■■■■■Rl.iamm■■.•.[luiriiiiii■aii■
aafMN[.fii/ mMan!RXIMaUrrlmanarl■aimmr�ar■a■r■.Iwm/>lmm■■mrrmu■■
r�.ww�.� _+r■m'■��mlalii■imm ilYtirrrrrrrrrirmi s■
■m■iri'/am No ■aiilliirSi:30CLC'�....1Y'r..._�+PGifiw`S�Tiioi�ii,7��ii�w�6B��i�iwiYi'i�
on
lr1aEMlE'a�s�EU aalomNmaiM/RESE�Elmlmf "N.<�■MaaiR■aM!■!a■E
■s■MrlasVIER ■MrlmlN■mi'ais■■isifEaammMmrif: /Y1aiilf■■m■■iifi■
+�E'[Eflma7L..mM■lamrr rMMrsommmr rMENNENrrr
w20,21H nw....:.:..:.+,.«.u„upu hw'jwrRMrarmMEETswam"
UM1 NRRaEM ■/aRRR:EE[.■mr.�=++�■■ma■Imala
E[�■ass■!i[IRMsmaffrlsam[,saEE� �w..�sM�mEmlE
Ns■m■smmmmamMEa■Mlaiaas!■u■immE.-lai■
•�Mmmmmmm,-. Mmmfr: • ■r: nMmm : r liRaFam■J,IM
ONE liRRSRaaRRElRlR■M■sE■RE■RRElE!■■VIE/l►r
alrm alaasssiasslsE■aasasas■mmR!':•.sswlls■
■aiM■ifaamarrfmrmwmr msrrrrrrrmMMwm■ ■.�•.f■
IN
■mRMRRMRsaamaNsasREasi■mmamm!lmmmEEsasia
■a■MMaaa■iiilalimMMiaaiiMri■iEmammrMm
EEm■ m■MMamMmalssisaEMRfiamRaslamMmmmmlEa
ammfM!■ii■ifmisail!■■maf■�alfMmliamR■si■
ilRaE■■■mMamMfMaEERamEaa! ■ mM!!i!■mMaaa
saa!■elimaaMaMfmMm■Nsmsmrmmmsmmamm■aMRmi
■ais■■■■MRSM■aR■ar■■Mm■s■■is:!■lmmmmmCA
mmMsmmmmmaamm■laammm/mmMi■maalafiisasiww
■■f!■a■i■■MMiamaim!■iamiiimiilammmmMMNEa
alma ■■N ■mmamm■fMfiaimia■aimmimmMmmaaii
■lEEEREaa!!1<a■R!!!aR>am"!!■!!Ri■s!!■!!!!R!■i!■fala!■!■!!■
mmmimamiiiEmim■iR■■a■f■mMRRmmRRaRMMama■i■amMm■■i■laam/VI
■■siiiiiissmmwrsrrrrrrlMfwii/rmsafsssssmisissi■sriilmm■
■aam■■!s!■R■R■aa■s■maRm■aaaMa■mmismamammsimalama!■VIaaan
■faMMilmEMaaaEiaamaamimi■asa■■m!!!■■/amaimamma■HHUM■
�rrrrM�lMrw�fAEiitiUNI::HIN MINE REMMN■■mmir[1MMfMINAH
!■VIE■Ra�VIVIREEE■■!VIa■■!■rrr..���=mgli■d::l I wasimii:stt:
■!■a■ Samos m■am.m!==,7, aalM■MRIaRR!■!■!!M!!
'-=z«rwraf■M■E■i■■■mf■■■malmmRsisESRi■rsisasE■E1sR■■
R■RRNRRlE■R■EEM■iamiRm■EEE■■Em■■RMMMaNONSENSE■nalm!■■■
HU■■sM■■■aiiaEMm■■iMimmlfmmmam■la■ilaiaaii■maimitiia■Mmm■
MiMUMVIiiaia■Mimi■■iMMasoRiilimMmmwi■mmmm■1Mm1Nrmm■
■■mimafmmaa■fEi■mmrmaMf■■afVIEii■mlMmataa■mfMM■Emm! MMa■
■mmmm■maamaa■i■am■ills■fmMMVIMMmmiMaiRiii■aiiagammimaM■
wiriwwim� �rarrlmrsurME Mumma
J•w:rfflM■liiw�■:■miMm■■!!!!■m!m■
•N■mpm'•"��raimlEsw■sERmaE■laREi!■
■1�Frw!■mi■lMpam as OEM MRMIMIi■!!!R
rmaCrlm■ar.��.rMIIENEMMMN ■mfmlaMi
mlxw. - ---ms■maalrNmmmmmml■mmMmmwm
■.Rr■isk!■■Rrm��lamas ■a18■■UNI■1as
s w wrrMrsssisiias■
am"■VI■mmmmamE■■■ma■
mrwrrwmiimrwrrrrrr
■■■lamiimMaslaaM!■
■mmRlMsimlMmmiRmii
■sf■MMMmammMmiHN
rlMmmimmaamm■imEs■

+0
I f
%y�.j
'0 t, hcil I`rI'r ♦A.fir +#i%rj'i.�9Gd�a�SR.iit�:4,�IA'..a'�+.`,'�ASi7L3tr.�rP�t4�ti
r' � •1r �c Y is �. `t � ��.X,y�•i
n i �, •, , t I yE` { • ' � • • I � � fir►+�•
I
.e
lI RrigaavelerI rtlon, � ,..�.
4-1
r r ± �ti l �' +'� r. r% '-j
.` r. *�/ a�. ��MiJ .I } x'Y �.1 •'I_,r,7 �._, -,a, a .���� v r
r '
AL
it
1
1 r �
Af r I� ; I �
� _ y Y � 7 : P I1-, I`i S! � •'°"`fir + t ` I .
��: , xk � .}1��4',�l�� iy '!�� .S^ Iti,lk,• �. � ,tLl `+t f4 _�
• iS o � *f � �';'r, I ��1 ��l.+�^'. `,�,...4��.'�3 _ j .� '�� 'i'rY�lPir`�31i':'�
AJ b r �
!� � yl } ' S�IA ���i� III �•' 1. Yr ! i4 'r«.t +,r ,_ ! I r I r „w i �} �. ��pip11�
p A r,e �r,'ri C+•� I �yA`n v ANY. v I Y'�+I !' I r,r'�� r ; � S+�'{^ R t if
q��'.j xA •t -�v'r I { III ,y -i n t lw t -r s r.�•
r r - �Al y� "I'• I r i I r. r u 'd i � r
!'1 li t, , 4 i
,
r {. � r i � { , p i-• I, y t! l ' if.4L '. - r 1 i t r.t r
���� 7}i'., � `�d ��'`�7'�f}111M$t �,•r$#A4T ���!{;p�-.+g rdE r��l(+ti �Iyii ii,,r yM �A'I' K-S I,}�� # A, r! 3 tC}- � `,' j '-r 'YAe rr e� I?�' �,: nh 4 .+'' A.1
�` � � � r k,� � � �: how .•RAM �,� r �I } �^ w ap IV 'r> �} I �� �4
1,4
I1 1�,.,,,,.r.r..r•^'M rr P Y�r E .t r' // ,�tr .l� o. �i I p r. y "''•'^„f a�'I' '' +
� � I ' �� • � Ia rtia� +^'.ai v, � .'v. Y;I',j-Y j) �i.l
J q Tj r 4 1.4
}� rr 1:
�tl�fL}. i I' j,� � !` rl,I�rlF�f ,ri l � {41� '.l�; I }..l � �, d � 1 � �� w � I } dl `'g �•'
"t!�;..C.
u�.rG.+t�r�'+,},� lt.. � '�J�' ta. -.'�' �kfrl il�nk�•�iii �r':r, �'.n! ',r,t, ,I ^�M�
-
1:',='i�
'�� i� ys.4 Y�AI >Y �r.�r�`�'J!` sr � Sg ? ;ud •, �, � r + a � ic•w•ti. �(� '17 ... A4} ,r•' '� r; i 'i.3.:, ,`
au$,Fk �Y�;,I� 4rrt. J A � � Yy �H�'tll ' Iii, ■ 1 � 1 '�f�,�h r i �'� t 1kj,�.11
1" �A m', frC *fr.r rrn.r;�4a v�p � '• �SSryA �,,{ 1 rl f'jyien N, .' ..+��f,+', ;� jhr'.
a %I d�'•e i�' �' � {� V t ,, � , y} I jjjjrQ I ��._ V I��y" { I. � 1 4 w1r. ^1►
,. h 1a 1 i•...,

Improved Design Provides Greater Operator Control
Greater control ... more accurate application of both clean and
wastewater. Simpler to operate ... the smooth operation of the six
speed gearbox eliminates
the need for multiple belts
and pulleys while providing
a full range of operating
speeds. Within a high and
low range there are three
speeds for increased preci-
sion and accuracy in con-
trolling application rates.
Knowing and controlling
your application rates have
become crucial wastewater Six speed gearbox
management tools when
trying to adhere to ever increasing regulations. Each model is
available with the standard 5.5 HP Honda engine or the efficient
Pelson Wheel slurry
turbine. The Pelton
Wheel turbine is the
Pelton Wheel slurry turbine
only starts with the drive system.
ideal drive system for
applying wastewater
or slurry from holding
areas such as tanks
and/or lagoons. The
Pelton Wheel turbine
can be mechanically
compensated for
accurate applications
or equipped with the
optional Irrigation
Computer.
This improved design
Other enhancements include:
• A constant pressure automatic braking System which
increases tension when the hose is being pulled out but reverts to
lighter tension as the hose is being retrieved.
• A positive action lock down. When engaged, this simple
brake will lock the reel in place when shifting the gearbox to neutral,
as well as secure the reel for transport when desired.
• A miswind sensor. Should a miswind irregularity ever occur,
this sensor will automatically disengage the drive, protecting the
.Reel Rain from damage.
• Large selection of models. In an effort to offer customers
the proper system for their irrigation needs, Reel Rain models are
available in 29 different hose size 1 drive platform configurations.
• Increased
speed range.
From .5 feet per
minute to 12.5
feet per minute,
you have the abil-
ity to control the
application rate.
With Reel Rain
Irrigation equip-
ment from
AMADAS
INDUSTRIES,
you and your
Dealer receive Reel Rain Model 1375
special attention from our fully equipped Service Department
Each Service Technician is trained by the AMADAS staff el -
who designed your Reel Rain. The 1000 Series offers only
STANDARD
FEATURES
• 6 Speed Gearbox
• P.T.O. Rewind
• Automatic Hose Retrieve
Stop
• Rugged Frame Design
• Turntable
• Reel Speed Compensator
• Safety Shielding
• Galvanized Fittings
• Galvanized Gun Cart
• Mechanical Hose Guide
• Three Year Warranty
• Miswind Sensor
many dependable models
of Reel Rain Travelers. Ask
your Dealer to show you
other models that might
meet your needs. Reel
Rain Travelers are avail-
able in models which will
efficiently irrigate from 35 to
400 acres per week,
61 V%® HQBBS.
wiles W Reel si min
No. of Acres
Flow Rate
One Pull, Applying 1"
Model
Hose Length
Hose I.Q.
Lane Spacing
-Covered In
(G.P.M.)
of Water (Hrs.)
Nelson Gun
Number
Feet
Inches
Feet
One Pull
and Pressure
Turbine Gas
Turbine Gas
1025
850
.2.5
180
3.80
167 181
10.33 10.65
SR100/80 PSI
1030
965
3.0
240
5.84
260 280
10.2 9.4
SR150/80 PSI
1033
850
3.3
260
•5.68
360 400
7.1 6.4
SKIM= f
1325
1250
3.2
240
7.41
266 290
12.6 11.6
SR150/801
1376
1100
1 3.6
1 280
1 7.78
1 382 418
1 9.2 8.4
S111150180 PSIJ
n r ct A
1100 Halland Rd. • P.O. Box 1833 • Sulfolk, VA 23439-1833 f L-X J, WU ,��. �y 1701 South 5lappey Blvd. P.O. Box 3687 •Albany, GA 31706
Phone [phone] • Fax [phone] Phone [phone] • Fax [phone]
A AAAn A JAinrlcrrail=c' ;� n„a nf...,ntln,,.,,,� imnrmiamnnl _aM wa+rr.,rnnrn thn rinhl In rhnnna cnnr;1;c.g1;nnc dpsinn nrnrirPc wilhnnl inrurrinn nhlinn inn

5Q/95
Producc!r:
Loc�tion:
Addres�:
Tel�phone:
Typ" Operation:
Hu01.1er uF ��n�mal Units:
Aul
The wat;;te from your animal fac-ility must be 1An6 mpplie,d at a
specified rete to prevent pollution of S_,urface and/or ground water.
ThC' plant nutrients in the animal 1,40ste should be used to reduce the
awmunt uf commercial fertilizer reguirmd for the n the fields
where the waste is to b� applied. TF)is waste utilization plan u�e�
-.-I I- as 1-h0 limiting nutrient, Wasto should be analyzed beforC.-I
each`application cycle a/xj annual soil tc.mmts are strongly encouraged
so that all plant nutrients can be balanced for realistic yields of
the crops to be grown.
Several factors are important your waste utilizatiom
plan in order to maximize the fertilizer vAlue of the waatV an6 to
vnsure that it is all pliC-16 in an environmentally safe manper. Alw.1ys
t,:�pply waste bilsed mn the needs of the crop to begrown and the
nutrient content of the waste. Do not apply more nitrogen than the
crop can utilize. Soil types are important as they have different
infiltration rates, leaching potential-,, cation exchanQe'capaciti��,
and availahle water holding capacities. Normally, waste shall not bo
applied to land eroding at greater th�n 5 tonS per �cr� p�r yo��.
Uikh special precaution1:4, wast.e may be applied to laixd eroding at t I,p
to 10 tons, peir ye,7.,ir. Do not apply waste on saturated soils or on land
when the surface is frozen. Eithc..�r of these c01"I6itionS may result in
runoff to surface waters which is not allowed under DEM regulations.
Wind condition�shou1d a��o b� considered t� avoid drift and dnwnwind
odor problems. To vlaximize the vZAlue of nutriESnts for crop production
mnd tn reduce thO potential for pollution, the waste should be applied
to a growing crop or not more than 80 days prior to planting.
Injecting the waste or disking will conserve nutrientS and reduce odor
prn6]ums.
The acreo needed to apply the animal waste is, 6asied on
typicel nutrient content for this typo uf facility. Actual acreagca
r*.�quire(i ients; In ay.be more or 1ess and should be based on the waste
an�1ysis report from your waste Attached you
wi]l find information on proper sampling technique5, preparation, and
tran�fer of wast-e samples to the lab for analysis.
Thiu1;ilization plan, if carried out, me etss the requireIII ento
for cumpliance with 15A NCAC 2H.0217 adnptecl by the Environmental
Management -,'Commission.
WUP - 1

5/2/95
.................9:4.iT' !f F`•i€T=k�iUlll`L= itiHIS
(. •{- L11,.. CI Cl L.t C: C_? d :1 f? I.. .�. �� cl 1•.
2v SdWt efrtow ea 1u er 11C sac/ i;r22b
4 ,�q 1.1 I -I 1. t S X 9' 9 7 wJ rA S t e? / -A 1-I i (I l a 1 L.0 I'1 i t / y C? <A l-- - 44/7, 1S Ca
.T. _:.r•,• . -ICJ._ 7-7pA
('11 rl O r_1 Yl t Of h d i t r- O,:a C! 1-1 (N) E)C? r Y F:' a r
L-0s.4, G.S /30
,-f__-- mil-IiInUA1 t_srli tS X _3 __._- _ 1tyr, hd/r rlxcna_11 1.1r1x t/yea�al- = /b3S
lbw. N/year.
F'1ppilyincl thlE< ahar,ve ramnl.snt of w,7a ste its a big job. You .hlo(.Ilci plan time
e#rld have? to 2pply the waste in a timely mariner.
Set, e ,ath,FL(Thlnd Inap(sa) tihowi1.1g the -fields_; to be (..l_;rad for th(i? 1.11,iIi:.,ati.011
al'lifrlal walsl:r?. Th1e f'l}11C}wJil'lC.l ac1'ea1ga will bFa neeedP_d 'For was.i;s-?
based on the cr op to grown and method of app l i.cat iorr:
Table 1. ACRES Clt•1NED BY PRODUCER
Ir<:.1c:t field Soil Crop Rea L.L)s. N Acres Lb,. N morlt:h t.f'
J.:'I- y p ea Y i c:a l d C' e r" Ace 1/ U t; i t i. 7 ra d A h:)p 1 i c a t i, o n
t/ 'hlli. VI i.ca frc:fll anit"al wastin only. l'f I-lUtri.ents 'from other se-ktrc:es
f I'1 r.3 i commercial -Fee-t i l i i:e.'I- arC? applied, they mt..t sty bu ciC;Cw(=�1-11"i -ed 'fCo .
r'C,i'!.R1. N FrlUSSO; be based o1"1 crop yield F_';:pE'ctaticivi.
h' ! E„] l ETI' 1 +? _a3 C1�] l x c a t C:, r- i s C: ,l l l is i c:1"1 C-,? d that P eiavid 1 : m a y i:i 6? (::: V_ F.? I'-
aa plied while meetincl the N rocuirements. Det inninc in 1996
I,hle Coastal :'-onea Management Act will rL?quiru f-z.k "(ner s; iY'I, 55L-me?
easl,er-tl CounUi.C?_s of North Carolina to have a nutrient:
f l'i e11"I r ea (Ilk'? l'l t: plan that ai (:14:11'- a sa :.a e s all I l u t r i ti21'l t s. I' h1 i a w a =9 t ea
E31al ovily-�cidre se Nil,l'Urae1�.

. . �'. .
� . .
5/2/Y5
IS
TjbL1 ��_ ACRES WITH AGRE2MENT OR LONB TERM LEASE
(Agrooment with adjacent landowner must be attached)
(Required only if opnrator does not own adequate
land [see Specification 2])
Tract Field Soil Crop Real. L1 N AcreS; Lbs. N Month of
It Type Yield Per Ac1/ Utilized Application
!/ See footrmte for Table I.
'
Tjabllu_3._APPLlCATION OF WASTE BY �RRIGATION2/
�
2/Irrig�tion �ystem Dosign 'u�t be attach�6.

1. Anima] waste shall not reach surface waters of the state by runoff,
drift, manmade conveyances, direct application, or direct discharge
duriwg operation or land application. Any discharge of waste which
reaches surface water is prohibited. Illegal discharges ere
quhject to the asseesment of civil penalties of $10,000 per day by
the Divinion of Environmental.Management for every day G/e
discharge continues.
2' The Field Office must have documentation in the design folder
that the producer either owns or has long term access to adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he shall
provide NRCS with a copy of a written agreement (sample Enclosed)
with a 1pndownor who is withi// a reasonable proximity, allowing
hij/her the use of the land for waste application for the life
expectancy of the production facility. It is the responsibility of
the ow/e/ of the Facility to secure an update of the Waste
Utilization Plan when there is a change in the operation, increase
in the number of animals, method of utilization, or available ]and.
�. Animal waste shall be applied to meet, but not exceed, the
Ujhnuen needs for realistic crop yields based on soil type,
available moisture, historical data, climate conditions, and level
of management, unless there are regulations that restrict the rate
of application for other, nutrients.
'/. Animal waste may be applied to land that has a Resource
Management System (RMS) or an Alternative Conservation System
=S). If an ACS is used the soil loss shall be no greater than 10
tons per acre per year and appropriate filter strips will be used.'
w|/cre ru`Iof[ leaves the field. These filter strips will be in
*d'|i/'ion to ''Buffers" required by DEM. [See F[lTG Standard 393 -
FIltqr Strips and Standard 390 (Interim) - Riparian Forest
Rv�[ers.l
�^ Odors can be reduced he injecting the Waste or disking after wanks-,!
°pp1ication. Waste should not be applied when the wind is blowing`
6. Hhen a/`imol waste is to be applied on acres gubject to flooding, it
wili he soil incorporated on conventionally tilled cropland, When.
applied to conservation tilled crops or grassland, the waste mey be
brn*dcast provided the application does not occur during a mason
prm'e to flooding. (See in
the Technical Reference - Environment file for guidance.)
7' Liquid waste shall be applied at rates not to exceed the soil
inV)ltratton rate such runoff does/ not occur oFfsite or to surface
waters and in a method which does not cause drift from the site
during application. No ponJing should occur in order to control
conditions conducive to odor or flies and provide uniformity of
WUPS - l

. . '-.. .
. . .
application.
8' Animal waste shall not be applied to saturated soils, during
rainfall events, or if the soil surface is Frozen.
'
9. Animal waste %hall bo applied on actively growing crops in ouch a
".onner that no more than 20 to 25 percent of the leaf area is
covered. by solids.
W Want- "o+rients shall not be applied in full or wintnr for spring
Q )Av d crops on soilq with high potential for luaching. Wast o
noh'ie'`t loading rates on theme noils should he hu]d to a mihimum
and a s.,itahlQ winter cover crop planted to take op release�
netrjn"W. U+ste shall not be applied more than 30 days p.'iu`' to
[/!a'`ting of the crmp on hare soil.
!]. 4ri'ool waste shall not be applied closer than 25 feet to su,foce
wphc'' This di5tamce may be reduced for waters that arw not
P~'p,Wcl |`rcv3Hed adequate vegntative filter ships are presrnh.
Wpp S"Anda,d 393 - Filter Strips.)
1P' A")mz| waste shall noE he applied closer than 100 feet tc nwlls'
1') /\"i°'�1 waGte sh"\] not hc npp1ied c|nser than P0o feet of Jw"ll\ngs
"t!.r, than thosr owned by the la"duwner.
J. he applied in a manner not to rvach other prn|/ri ty a",I
public
15. Animal waste shall nut he discharged into surface waters,
'jrainagewayg or wetlands by a discharge or by uvmrspraying. Aoimal
wasUp may be applied to prior converted wetlands provided they have
Men approved as a land applicotion site by a "technical
speci*list". Animal waste shuold not be appllod on graSsed
notprways that discharge directly intn'water courses, and only then
at agronomic rates provided the application causes no runoff m'
drift from the site.
16. Pcmestic and industrial waste from washdown facilities, showers,
MUM,, sinks, etc., shall not be dischargod into the animal waSto
mawagement system.
17. Lagoons and other uncovered waste containment structures musl;
mainiain a maximum operating level to provide adoquate storage for
e [5-year, 24-hour storm event i" addition to the one (1) foot
mandatory freobosrd.

I., ....._,PI II I
ri u C5 1 z., E3 (I [l [ f) 1] 1. ::j y.'j I I :3 U V21 CA E.1 .1 U I V? LU Jt?
-i .;:i 1:1 :11 v E.) cl ft U a t cl 0 i-S 'C? Cl -,1 -0? '[ I E-J J 'E? Lt 0 1&, ::.j.
E) p) I- I o 1. :.q a 1 s .[ a a -.1 1 s d ul I t I C. I r IS 0 A V I I D I I.-t 'I S-' b LA T '[ 1-3 LA V? k (,3 C)
L.1 1'.) T SS C) A 0 fj LVC: U 1") f f1. V-1 1" f 0 d ' iLi 5 JU i f
C I 'C S S 0 Cl i3 L4 4 E3 4 'E3 L i 'E U i 't i:J I I 'C t.1 LI -3 'f Wl t Vi? T d F, A e
C5 ti T i. I i.,) uj E-a 1 d to L.1 't? f.") LA 'i U 'k V:1- fl Cl 1") A 0 J. 0 11 C s t.1 4:1 d 5:1 a -.1 sl _k a u mo a q '1 4 p a c, t t k(.i I E,
t 0 t:Y 0 V3 H Z,i d t: T) .� a Cl 01 -.:B '� {L 'I -E -D ej a Ll 4 .j iL k 0 -1.. -1 7)f-1 r.) 0 - k 4:1 fVfkO t 1.! rf J.
o e e a u,..) -E fs o _t e.5 J. 0 E-3 :3 Lk a p A y.O -A (3j. 4. 't A f-) [5 j:) ..t r) c.f -1 '.1 t:j 15 LA T F;. (M4 fj 1. 1
J 11:1 -.1 -t 5 11 LA V $L.'t0_lOCj U00bV-1 - i,) I C-1 1 E:l 15 a l ::? V? P LVE., PF3-1 OW :I 1.1 a :;j E..) C4 p -1 1 -IC) Ll
�.5 V.L�
V? CD C? LA 0 0 b u. a V., v j d o - k 1:1 e �3 - t a f3 T U 1. k f.) :1 E3 t C.3 L.J fli
:j 0 S 6 T D Ll Q 0 M A cj 0 LA V? 4 cS Cl Y-1 A L4 S 55 F, D _t q ES V L.1 :.:j Y-1 S.*? U Q T 1:..� i c...)
0 �JV?.� .-3 3 a L4 fl I D0.1 O.J d o 'I. 75 .3 -:) ei 1. t ES1'? a :3 I-t Elj, D (A
f-) Lk �0 E, Ve 0 - I V? 0 H 0 k_1 '.'i A -.'�J. E) 13 T A 0 A Cj 8 Cl I I V? k.1 S U 11: -11:-' & b FD A V? T D D d E� � I '� 03 1:: 1 E") E.) Ll J. .1
C3 tlk.01_k 0 Ci 1 Cl Si UJ ."t a cl "ss .I. k..i �:j kil �� I I. t e c.I 11) C.Ll I, t Q Q f .-;3 1:- a C.1 J Y-1 .-� s r. k:;
c J �.3 cp A 'r
CI V? E-3 Ea ut o v , . %
. . . . . . . . . . . . ..... I.,..,.., ... I ............
...........................................
...........
r L
9&121�

. Aorw
` .
5/BY5
Your fiacility is designed for days of temporary storage and
'7-:.Lhsuld have the temporary storage removed on the aver�Age C-?v«arY
months. {n no �hould the volumc? of waste being stnred in
�mur structure exceed Elevati�n _______~__.
. .
Ca11. the Natur�l R��ources Cun��rvation Servicc._3 or Goi1, and
Cnnservation District ofFice aftmr you rF.0cei.v0 the waSte analysis
repmrt to obtain in dotermining the amount per acre tu
�p�ly and the app1ication rete pr�or to applying the waske.
NDTE�
^
N ti f �
.... ..... ..�
WASTE UTILIZATION -PLAN AGREEMENT
I (He) underst�nd, will and follow the and
the mpetion and established in the approved
animal waste utiliZation plan for the farm named above. I (We> know
tha1, any expansimn to the existing design capiacity of the waste
treahment "and/or storage syF.-;trm'm or conmAruction of new facil1ties will
reqoire a new utilization plan and a new certificatinn to be submitted
to DEM beforS� the new animalS I (We) almo understand
that there must be no discharge nf an:imal waste from this systF.'2m to
surf�c� waters of the s1;mL-e fnr any rea�op ex�ept �torm events a�
severe as t�e 25-y�ar, 24-hour �torm or greatmr. The DEM regulations
re(:juire a copy of the approved plan be filed on -site at the farm
of'fic� and at tho office of the local Soil and Water Conservation
District will he available for review by DEM upon r'F:?quc-vst.
Fa,ilure to comply with the waste-, utiIizEItion plen will automatically
require any cosi. SihAre funds to be-� refunded to their sourcC?. '
SJgnAtur�� ��/ _ / Date:
8
Uame of Manager
Siynaturex
WUP - O

5/BY5
Where ownere nf
animal operations do
not have
adequate awounts of land
tm upply the waste,
the producer munt
provicJe
a wriAtc-n agreement
w�ereby another
landowner has agreed
to Iand
apply or :111ow lam6
applicahion on
his or her land. The
attached
agreemenI; mJAY be used br
some mther documentation
may be provide].
.
ADJACENT LANDOWNER AGREEMENT
'
underst�.!knd that MI./Mr�.
'|c�s not have ample lend to apply the animal waste produced from
operation. I agree and give for Mr./Mrs.
�o apply animal waste from his Waste System on
of my land for the., duration of time? shown below.
I furt41 c.71 - understand that thi�-, wate contains; nitrogQn, phosph�rous,
�nta�sium, and other nutrient elements end when pI applied
�houl6 not harm my land or cropS-,. I alc;o underskand tha� tho use of
1:his waste will reduce my need for com1110rcia] fertilizer.
lerm of Agr�ement: �9to 20__
(Minimum of Ten Years on Cost Shared Items)
(See Specificat\oo No. 2)
Fk,ecipient Landowner (please print): ____________________________________
Signaturm; Dat(--: _____________
PLAN APPROVAL
AVfitiion (Age'`cy>:
-�
S>ynat"re: _��� �Date:
SWCD BOARD REVIEW
���CD Repr��ontativ� (please print): ________..... ______________--- ___________�
UUP - 9

%
A "A
'sib
1114�
zn
A- Zt
4'i d
Zq� pj� 7 V p 0
.4. -.4
:;otr 'r
fit
IT r•
Ur j
e4-
f75 7e
A�
wy
. 0 -
}I.' N-AN IP6 A
..........
44
-41
44 t

gill
w'
V7,
arl �ITrr '� 1 ?1�,,►1 '�1 14��.ff
®r�'
{t ' j�1•. ,R%) '� 't•'. �, yig{j1' ,,,.
umsit
.`.♦ R � r+ _,1 rep • ' ,� r ,; �, t ,�� � � �
oj
} 4 .1 'r ..1lrf.k., ``1 .L .l i 1•Y''. F
.�" ,.]�' �. L •.::1n� ; �' ` dry Ili'
t ;1 ,I�,j{q��!rt'T, .� '�.• 1q; •� '"� r .�,.'['• ��; rrf 7
(irr'�IF {- .i �'Q'�'j r..•e '1h'�lr �j''' �+' I( s'
IPA
. ,. ,,,f � ,tom. -fie• �� �. -�,} r,'•
sAV
dry r�� - � • 4 r<• �.� • ' •'` •`. +'��1
is
.aIFV.rr •tiA
i;.. �.�.:., I I 1, hw ,r I. 1 r�,�a 1f' •r srri r irv; l

'If
Irrigatimi Parameters
for
Animal Waste Management System
Landowner/Operator Name: u % i /-/—e SZ a._ Date: 2-2 9G
Address: z
a es wi Ile N ,
Telephone: / 7 2S7
TABLE I Field Snecificationst
Field
Numberl
Size
(acres)
Slope
(c)
crop(s)
Maximum
Application
Rate (inthr)
Maximum
Application
Per Irrigation
Cycle3 (in)
/8
1
Corn
. 3.5
2.3 S
1Table to be completed by Soil and Water Conservation District (SWCD)
personnel
2See attached map provided by the SWCD for field Iocation(s)
3N. C. Irrigation Guide, Field Office Technical Guide Section II G
TABLE 2 Traveling Irrigation Gun Settings
Make, Model and Type of Equipment:
Field
Numbert
Travel
Speed (R/min)
Application
Rate (in/hr)
Travel Lane
Spacing (R)
Equipment
Settings
el ..
.'31$
.2-?0 "
�?- 90
'See attached -map provided by the SWCD for field location(s)
USDA-NRCS
page )
NC Arw I

A&
TABLF 3 Solid Set Irrigation Gun Settings
Make, Model and Type of Equipment:
Field
Numbed
Number of
Hydrants
Distance
Between
Hydrants (It)
Application
Rate (in/hr)
Operation Time
At Each
Hydrant (min)
'See attached map provided by the SWCD for field location(s)
TABLE 4 Irrigation Svstem Snecifications
RAVELING IRRIGATION GUN
SOLID SET IRRIGATION
Flow Rate of Sprinkler (gpm)
7 pM
Wetted Diameter (ft)
Design Precipitation Rate (in/hr)
.310
Hose Length (ft)
965
--------------------
Travel Speed Range (ft/min)
P/1VI i n
--------------------
Speed Compensation (circle one)
YES NO
--------------------
TABLE 5 Thrust Rlncic Snecifications
LOCATION
THRUST BLOCK AREA (ft')
90o Bend
�(G p
Dead End
.3.3 n f
Tee
J , 3 f
USDA,NRCS page 2 NC Aren I

Irrigation System Designer Name: 62Aev w. 44A+tlV.,M -
Company: Vette A CEeL- 4eo&ut7-S
Address: w Aroa s E
'/c a7aS
Phone: /9 ) _398 _ 311A,
NOTES
1. A scale drawing of the proposed irrigation system must
accompany this form for review by USDA-NRCS engineers.
The drawing should include hydrant locations, pipeline
routes, thrust block locations and travel lanes where
applicable.
2. A buffer strip 25 feet wide or wider must be maintained
between the limits of the irrigation system and all perennial
streams or surface waters per DEHNR-DEM Code Section
15A MCA 2B .0200 - Wasfe Not Discharged to Stir
Waters.
Narrative of Irrigation System Operation
Briefly describe operation -of the system in the space provided below. Include
procedures such as start-up, shut -down, winterization and regular maintenance.
0 eG q.110 r-A r c 5 A ec
USDA -\'RCS page 3 NC Area 1

Narrative of Irrigation System operation
Describe the operation of the system in the space provided
below or on a similar sheet most convenient to the
designer/supplier.
Include procedures such as start-up, shut -down, winterization
and regular maintenance of all equipment.
This irrigtor is designed to apply .48" of water at specified
ratings. Pump should be primed and started and 1030
traveling hose should be extended to specified destinations
in accordance with map. The reel should be started in manner
that is given in owner's manual that accompanies the machine.
The machine is equipped with shutoff system, so there is
no harm done to the machine itself. The irrigator should
only be ran in accordance with the waste management plans
and to the specifications of this design.
Winterization should be done when the machine will be shut
down for more than a month at a time, during the winter
season. All water should be drained and machine should
be greased and oiled.
Regular checks should be made on the reel, hose, and all
mechanical equipment on the machine itself.
s

TABLE 14--1HRtIST BLOCKING AND ANCHORS FOR UNDERGROUND TIM GAT1ON PIPELINES
` r
e: MC.4
Step 1. multiply Om woddnR; premwne by the appropviate value
shows in dbe fdlewfsd table to obtWn total thrust In N Ob):
two dam
Bead end
9e°
4e
22 W
Im.
mm
or tee
Elbow
lllbow
Elbow
1%
48
294
4.16
2.25
.1.13
2
60
4.64
6.45
3.50
1.78
2%
73
6.65
9.40
5.20
2.60
a
69
9.80
13.9
7.61
2.82
3%
102
12.0
16.1
0.81
4.99
4
114
18.2
23.0
12.4
6.31
6.
... 141..:•
,i4 ..,......
46.0
18.0
9.63
.7.:::.,
6:':";i:::v:i9�v:'. •e'r:wf�::.:.:•:fir•:'�'ti�•:.�:��:�}!:�:;%%%l!1pi�4:�:;:::«;!::v;;aid::;::..
a
• 210
59.6
s3.6
10
273
.,
91.5
180.0
70.0
36.8
12
324
129.0
182.0
98.6
50.3
14
ass
160.2
226.51
122.6
02.6
16
' 389
1e8.9
$40.0
140.7
71.0
16
406,
201.1
284.4
163.8
73.6
1s
475
274.7
388.4
210.1
107.4
20
bla
32"
462.2
250.1
127J
21
560
281.8
539.9
292.i
I49.3
24
Sao
48"
683.2
369.6
188.9
27
710
613.7
867.8
469.E
239.0
•Based on thrust per kPa (pd) prosgum
f111000nd for *ton may not be needed wltb lone branch Ifnes.
Stop 2. Deimrmho the bamAna ltrenlifh of the moll Isom the table
bmlowt
BEARING STQ.ENGTH OF SOILS
Sills and mate beachm toads
lbftt2 kP4
Sound +bale
10 000 goo
Cemented anal and pad
difficult to p"
4 000 200
Coom and fine compact sand
3 000 ISO
Medfum slay-cie be spided
0 . QQ,� • � : :
�:•:a:oH"t*W'>........,•...,..
Soft clay
muck
0 0
Step S. Divide Um total thtvd obtalned In Stop 1 by the beadog
Areas& of the mod to most the acme needed. m2(ft2).
SIDE TIMUST AI.TZRNA71" PROC>ZDU=
Pipe sire Side thmd-pm degree •
In. mm lb N
1%
48
5.1
22.7
2
60
7.9
36.1
Rita
73
11.6
51.6
3
89
17.1
76.1
3%
102
22.4
99.6
4
114
28.3
1269
a
141
43.1
191.7
6
I68
60.3
270.5.
8
219
103.0
468.2
10
273
160.0
71I.7
12
324
225.0
10002
14
sea
278.2
1237.4
16
$89
319.6
1421.6
16
406
349.3
1563.7
is
475
477.3
2123.0
20
61s
668.0
2526.5
21
goo
663.6
2951.7
24
6a0
689.6
3734.5
27
710
1046.2
4742.E
08esd on dde thtnst par $99 kPa (100 psi) premum per drsrse
of defleetdon.
NOM Multdpfy vide thrust hom table by depteee of deflection
times We (psi) dltided by 100 to obtalp total aide thrust in N (lb).
510 ASAE STANDARDS 1987 ,

1=;
�r, Rv
2
"0
Sr".
t 46,
to
4L
00
vv
P4 ... •1, : I. .rti Yi •r .�; 'y:�.%1'r:. .,r 1 'M •�t1 'il j, �r .Y.•. • +i•�'• �, [. �, • �. �'\.
qr
44 1
to
OF f
W"
104

ti•.
RECEIVED NOV o 1 1998
UNITED STATES Natural county Agriculture Building
DEPARTMENT OF Resources 403 Government Circle, Suite 4
AGRICULTURE Conservation Greenville, NC 27834
Service Phone: [phone]
SUBJECT: Paul Lilley Date: October 30, 1996
Waste Irrigation System
To: Mark F. Pollard
Soil Conservation Technician
P. O. Sox 61
Gatesville, NC 27938--0061
Enclosed please find the design for Paul Lilley Waste Irrigation
system. I have reviewed the information submitted to me and the
plan is approved subject to a minor correction on the pump
horsepower. I made the correction on the design.
Once the system is installed, a letter of certificationis needed
from the irrigation installer confirming the system has"been
pressure tested'and has'been'installed according'to NRCS""
standards and specifications.'' -,You are encourage to make one
field visit during installation. Approval for cost share will be
based on this certification.
If I can be of other assistance please don't hesitate to give me
a call.
0/
#4246C�6 ,
Claude M. Long
Civil Engineering Technician
cc: Gary W. Manning
G. Douglas Jones
Joy Sherrod
r

l i.
REVELLE Aam PRODUCTS, INC.
P.O. Box 06
508 WEST BROAD STREET
MURFREESBORO. NORTH CAROLINA 87855
TELEPHONE (OM 398-3116
Mark F. Pollard
Soil Conservation Technician
PO Box 61
Gatesville, NC 27938-0061
Dear Sirs:
November 4,1996
The Hobbs 1030 Hard Hose Traveler, Ravotti PTO Pump, and 6" Aluminum Pipe has
been delivered and set in place at Mr. Paul Lilley's in Gatesville, NC. This equipment and
design meets all design and installation specifications set forth by our design group at
Revelle Agri -Products. This layout is in accordance with the plan approved by Mr.
Claude Long, Civil Engineering Technician, of the NRCS office in Greenville, NC.
My own crews delivered the pipe, and equipment to farm, and made inspections of all of
the equipment before leaving the site.
At the delivery, Mr. Lilley was provided with information on how to operate, maintain;
and service the irrigation equipment our office provided him with. We have laid out an
irrigation plan that meets all North Carolina laws, and if properly followed will apply the
specified amount of water. All pressures, running times, and specifications in the plan
must be followed to meet approval.
If you have any questions or need anything else please call me at [phone].
Sincerely,
�JnW
lA) . O"W"�
annin Ga
r}g
Irrigation Designer
Revelle Agri -Products, INC.

lfi4 z9 ° ail f6 P Ins c!"4€ a t"F t" orS E ��i! �Wrv.°.�" i '3 w ^tzl r g 3 c 5U1 717; i' -11 �� 9 � 1 i4 S
�' �` ► WASEJ`I'TLIZAT�4N= �'L�N ` '
, t � 1,
„ � fi �� FOR SWINE.OPERATIQN
t1;f, # ! i Er}� a t;
SnE ti €€ ae E 4 Sp22 k} f .Y.�.}..,
[� 9j �49�f Eq � n.l, 1; i 9efr-: Y y si �in•�';Ft € E �'.,
esx� 1 so 't.- < �, a° e
I.
n , ,, ; Feb�irA - ; -9, -, 01x
Producer:
Location:
Address:
Telephone:
Type of Operation:
Number of Animal Units:
Paul Lilley
NC 37 1 Mile of Gatesville, NC
146 NC 37 South
Gatesville, NC 27938
252-357-2575
Swine
90 Farrow to Finish
RECEIVE .._. ._. _.
WATER QUALITY SECTION
APR 2 2 20 22
NON —DISCHARGE PERMITTING
The waste from your animal facility must be Iand applied at a specified rate to prevent pollution of surface
and/or ground water. The plant nutrients in the animal waste should be used to reduce the amount of
commerical fertilizer required for the crops on the fields where the waste is to be applied. This waste utilization
plan uses nitrogen as the limiting nutrient. Waste should be analyzed before each application cycle and annual
soil tests are strongly encouraged so that all plant nutrients can be balanced for realistic yields of the crops to be
grown.
Several factors are important in implementing your waste utilization plan in order to maximize the fertilizer
value of the waste and to ensure that it is applied in an environmentally safe manner. Always apply waste based
on the needs of the crop to be grown and the nutrient content of the waste. Do not apply more nitrogen than the
crop can utilize. Soil types are important as they have different infiltration rates, leaching potentials, cation
exchange capacities, and available water holding capacities. Normally, waste shall not be applied to land
eroding at greater than 5 tons per acre per year. With special precautions, waste may be applied to land eroding
at up to 10 tons per year. Do not apply waste on saturated soils or on land when the surface is frozen. Either of
these conditions may result in runoff to surface waters, which is not allowed under DEM regulations. Wind
conditions should also be considered to avoid drift and downwind odor problems. To maximize the value of
nutrients for crop production and to reduce the potential for pollution, the waste should be applied to a growing
crop or not more than 30 days prior to planting. Injecting the waste or disking will conserve nutrients and
reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content for this type of
facility. Actual acreage requirements may be more or less and should be based on the waste analysis report
from your waste management facility. You will find information on proper sampling techniques, preparation,
and transfer of waste samples to the lab for analysis in your Certified Operators manual.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC 2H.0217
adopted by the Environmental Management Commission.
1

Amount of Waste Produced per Year
90 animal units X 19:9 waste/animal unit/year = 1791 waste/year
Amount of Nitrogen (N) Produced per Year
90 animal units X 26 lbs. N/Animal unit/year = 2340 lbs. N/year
Applying the above amount of waste is a big job. You should plan time and have appropriate equipment to
apply the waste in a timely manner.
See attached map(s) showing the fields to be used for the utilization of animal waste. The following acreage
will be needed for waste application based on the crop to grown and method of application:

WASTE -UTILIZATION"? LAN "
� �. N' � i':f £ �'� < < R" � �°���1 l.lflll �l M� � �����1 � �-: � �� i G t �ti "I5� ��' ��� �-�.� �t}.•�
Table 1: Acres Owned by Producer
-ti
Tract
No.
Field
No.
Soil
Type
Crop
Realistic
Yield/Acre
Lbs./N
Per Acre
Acres
Lbs.IN
Utilized
Month of
Application
92
1
RoA
Fescue
2.5 Tons
125
6.8
850
Feb. - Oct.
92
2
RoA
Corn
120 bushel
150
6.2
930
Mar. - July
92
4
AtA
Corn
130 bushel
163
4.4
717
Mar. - July
92
5
ToA
Corn
130 bushel
163
13.5
2200
Mar. -- July
92
7
AtA
Corn
130 bushel
163
4.0
652
Mar. -- July
92
8
AtA
Corn
130 bushel
163
3.0
489
Mar. - July
TOTALS L-37.9 1 5838
__l
OR
Tract
No.
Field
No.
Soil
Type
Crop
Realistic
Yield/Acre
Lbs./N
Per Acre
Acres
Lbs.IN
Utilized
Month of
Application
92
1
RoA
Fescue
2.5 tons
125
6.8
850
Feb. - Oct.
92
4
AtA
Cotton
850 lbs.
102
4.4
449
May - July
92
-4
AtA
Wheat
50
4.4
220
Oct. - Mar.
92
7
AtA
Cotton
850 lbs.
102
4.0
408
May - July
92
-7
AtA
Wheat
50
4.0
200
Oct. - Mar.
92
8
AtA
Cotton
850 lbs.
102
3.0
306
May - July
92
-8
AtA
Wheat
1
50
3.0
150
Oct. - Mar.
TOTALS 18.2 2583
OR
Tract
No.
Field
No.
Soil
Type
Crop
Realistic
Yield/Acre
Lbs.IN
Per Acre
Acres
Lbs./N
Utilized
Month of
Application
92
1
RoA
Fescue
2.5 tons
125
6.8
850
Feb. - Oct.
92
2
RoA
Wheat
55 bushel
132
6.2
818
Nov. - Mar.
92
2
RoA
Soybeans
44 bushel
88
6.2
546
May - Aug.
92
4
AtA
Wheat
60 bushel
144
4.4
634
Nov. - Mar.
92.
4
AtA
Soybeans
45 bushel
90
4.4
396
May - Aug.
92
5
ToA
Wheat
60 bushel
140
13.5
1890
Nov. - Mar.
92
5
ToA
Soybeans
45 bushel
90
13.5
1215
May - Aug.
92
7
AtA
Wheat
60 bushel
144
4.0
576
Nov. - Mar.
92
7
AtA
Soybeans
45 bushel
90
4.0
360
May - Aug.
92
8
AtA
Wheat
60 bushel
144
3.0
432
Nov. - Mar.
92
8
AtA
Soybeans
45 bushel
90
3.0
270
May - Aug.
TOTALS
37.9 1 7987
3

OR
If Crop Rotation Follbws Soybeans Use This Table
Tract
No.
Field
No.
Soil
Type
Crop
Realistic
Yield/Acre
Lbs./N
Per Acre
Acres
Lbs.IN
Utilized
Month of
Application
92
1
RoA
Fescue
2.5 Tons
125
6.8
850
Feb. — Oct.
92 1
2
RoA
Corn
120 bushel
130
6.2
806
Mar. — July
92
4
AtA
Corn
130 bushel
143
4.4
629
Mar. — July
92
5
ToA
Corn
130 bushel
143
13.5
1931
Mar. — July
92
7
Xt—Al
Corn
130 bushel
143
4.0
572
Mar. — July
92
8
AtA
I Corn
130 bushel
143
3.0
429
Mar. — July
TOTALS 37.9 5217 -]
OR
Tract
No.
Field
No.
Soil
Type
Crop
Realistic
Yield/Acre
Lbs.IN
Per Acre
Acres
Lbs.IN
Utilized
Month of
Application
92
1
RoA
Fescue
2.5 tons
125
6.8
850
Feb. — Oct.
92
4
AtA
Cotton
850 lbs.
82
4.4
361
May -- JuIy
92
—4
AtA
Wheat
50
4.4
220
Oct. — Mar.
92
7
AtA
Cotton
850 lbs.
82
4.0
328
May — July
92
—7
AtA
Wheat
50
4.0
200
Oct. — Mar.
92
8
AtA
Cotton
850 lbs.
82
3.0
246
May — July
92
—8
AtA
Wheat
50
3.0
150
Oct. — Mar.
TOTALS 1 18.2 1 2355
1/ This N is from animal waste only. If nutrients from other sources such as commerical fertilizer are
applied, they must be accounted for. Total N must be based on realistic crop yield expectation.
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N requirements.
Beginning in 1996 the Coastal Zone Management Act will require farmers in some eastern
counties of North Carolina to have a nutrient management plan that addresses all nutrients. This
waste utilization plan only addresses nitrogen.
2/ (—) = Overseeded
4

j?VASTE UTLIrZA°TION PLAN E_ ; r,
ej
_«.I.a��,ca:.a3¢i-..,..,awsr..:.f.v`'F tff¢ f r ¢E r'
RSV tS qR iI q I 4 A A
a
g h K. FOR SWINE OPERA, TTON h p
r �#` � �. R¢:1 ¢ LE x s # a#' t f-x3#� � 3 3 p--'$�-- t 9i n• •,.x- - ; & e � �..
V
Fbru�a�r 1240,1
J' 3
Table 2: Application of Waste by Irrigation
Tract
No.
Field
No.
Soil
Type
Crop
Application
Rate (In./Hr.)
Application
Amount (In.)
92
1
RoA
Fescue
0.35
4-- 1.o
92
2 1
RoA
Corn
0.35
2-M t. o
92
2
RoA
Wheat
0.35
2-4-5 /. o
92
2
RoA
Soybeans
0.35
245 /, o
92
5
ToA
Corn
0.35
2-M 1.6
92
5
ToA
Wheat
0.35
/. o
92
5
ToA
Soybeans
0.35
4-% /.d
92
4,7,8
AtA
Corn
0.5
2-M /.0
92
4,7,8
AtA
Cotton
0.5
245 /.o
92
4,7,8
AtA
Wheat
0.5
14& /.d
92
4,7,8
AtA
Soybeans
0.5
1179 / • o
�1,gM�ts /�6kECA TD
4
t,�
d
SI-/�-ate
5

WASTE DISPOSAL SPECIFICATIONS
Animal waste shall not reach surface waters, of the state by runoff, drift, manmade conveyances, direct
application, or direct discharge during operation or land application. Any discharge of waste, which
reaches water, is prohibited.
2. There must be documentation in the design folder that the producer either owns or has an agreement for
use of adequate land on which to properly apply the waste. If the producer does not own adequate land
to properly dispose of waste, he/she shall provide a copy of an agreement with a landowner that is
within a reasonable proximity, allowing him/her the use of the land for waste application. It is the
responsibility of the owner of the facility to secure an update of the Waste Management Plan when there
is a change in the operation, increase in the number of animals, method of utilization, or available land.
Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for realistic crop yields based
on soil type, available moisture, historical data, climatic conditions, and level of management, unless
there are regulations that restrict the rate of application for other nutrients.
4. Animal waste shall be applied on land eroding less than 5 tons per acre per year. Waste may be applied
to land that is eroding at 5 or more tons but less than 10 tons per acre per year providing grass filter
strips are installed where runoff leaves the field. (See FOTG, Standard 393 -- Filter Strip)
Injecting the waste or disking after waste application can reduce odors. Waste should not be applied
when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated on
conventionally tilled cropland. When applied to conservation -tilled crops or grassland, the waste may
be broadcast provided the application does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina " for guidance.)
7. *Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff does not
occur offsite or to surface waters and in a method, which does not cause drift from the site during
application. No ponding should occur in order to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that the crop is not covered
with waste to depth that would prohibit growth. The potential for salt damage from animal waste should
also be considered.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a high
potential for leaching. Waste nutrient loading rates on these soils should be held to a minimum and a
suitable winter cover crop planted to take up released nutrients. Waste shall not be applied more than 30
days prior to planting of the crop or forages breaking dormancy.
6

WASTE DISPOSAL SPECIFICATIONS
N
11. Animal waste (other than swine waste from facilities sited on or after October 1, 1995) shall not be
applied closer than 25 feet to perennial waters. (See Standard 393 — Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those owned by the
landowner.
14. Waste shall be applied in a manner not to reach other property and public right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands by a discharge or
by over -spraying. Animal waste may be applied to prior converted cropland provided a "Technical
Specialist" has approved them as a land application site. Animal waste shall not be applied on grassed
waterways that discharges directly into water courses, and on other grassed waterways, waste shall be
applied at agronomic rates in a manner that causes no runoff or drift from the site.
16. *Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall not be
discharged into the animal waste management system.
17. •A protective cover of appropriate vegetation will be established on all disturbed areas (lagoon
embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to protect the vegetation.
Vegetation such as trees, shrubs, and other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible. Berms and structures should be
inspected regularly for evidence of erosion, leakage, or discharge.
18. •If animal production at the facility is to be suspended or terminated, the owner is responsible for
obtaining and implementing a "closure plan" which will eliminate the possibility of an illegal discharge,
pollution and erosion.
19. *Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular basis to prevent
breakdowns, leaks, and spills. A regular maintenance checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops for direct human
consumption. However, if animal waste is used on crops for direct human consumption it should only
be applied preplant with no further applications of animal waste during the crop season.
21. *Highly visible markers shall be installed to mark the top and bottom elevations of the temporary
storage (pumping volume) of all waste treatment lagoons. Pumping shall be managed to maintain the
liquid level between the markers. A marker will be required to mark the maximum storage volume for
waste storage ponds.

WASTE DISPOSAL SPECIFICATIONS
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least annually at crop sites
where waste products are applied. Nitrogen shall be the rate — determining element. Zinc and copper
levels in the soils shall be monitored and alternative crop sites shall be used when these metals approach
excessive levels. Phosphorus shall be adjusted for optimum crop production and maintained. Soil and
waste analysis records shall be kept for five years. Poultry dry waste application records shall be
maintained for three (3) years. Waste application records for all other waste shall be maintained for five
(5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina regulations.
*Liquid Systems

Your facility is designed for 120 days of temporary storage and should have the temporary storage removed on
the average every 4 months. In no instance should the volume of waste being stored in your structure exceed
elevation 50.6.
Call the Natural Resources Conservation Service or Gates Soil and Water Conservation District office after you
receive the waste analysis report to obtain assistance in determining the amount per acre to apply and the
application rate prior to applying the waste.
Note: Sludge disposal is an item that will need to be addressed every 5-7 years. Your facility will
provide approximately 562 pounds of plant available nitrogen (PAN) per year in the sludge. If
you remove the sludge every 5 years, you will have approximately 2810 pounds of PAN to
utilize. If you apply the sludge to corn at the rate of 125 pounds of nitrogen per acre, you will
need 22.5 acres of land. Please be aware these are only estimates of the PAN and acres needed.
Actual application rates will be based on a waste analysis of the sludge after the sludge has been
agitated, and the realistic yield expectations (RYE) of the host crop.
Narrative of Operation: This Waste Utilization Plan (WUP) has been amended to reflect the crop rotations
used by this operation. Table 1 shows the receiving crops and computations. This will allow the producer more
flexibility in managing the wastes produced, and provide an opportunity for crop rotations. The acreage shown
in Table 1 represent the minimum wetted acres needed for each crop. Field 1 is fescue pasture and is being
grazed. The wheat/soybean rotation will be a double crop with the wheat being harvested. The soybean RYE
has been reduced to allow for application on the wheat. Any crop rotation following soybeans will have the
pounds of Nitrogen (N) reduced by 20 pounds to account for the N residue from the soybeans. When the cotton
rotation is used, wheat will be overseeded (—) to allow a fall application. The wheat will not be harvested and
the pounds N per acre has been reduced to reflect this. These rotations or combination of rotations along with
the fescue pasture will allow full use of the N produced (1229 pounds) by this operation per year. A traveling
gun irrigation system is used for waste application.
Note: This WUP was amended this date per request of Division of Water Quality (J. R. Joshi) to reflect DWQ
changes for General Permit.

Waste Utilization Plan Agreement
I (we) understand, will implement and follow the specifications and the operation and maintenance procedures
established in the approved animal waste utilization plan for the farm named above. I (we) know that any
expansion to the existing design capacity of the waste treatment and/or storage system or construction of new
facilities will require a new utilization plan and a new certification to be submitted to DWQ before the new
animals are stocked. I (we) also understand that there must be no discharge of animal waste from this system to
surface waters of the state for any reason except storm events as severe as the 25-year, 24-hour storm or greater.
The DWQ regulations require a copy of the approved plan be filed on site at the farm office and at the local Soil
and Water Conservation District and will be available for review by DWQ upon request. Failure to comply
with the waste utilization plan will automatically require any cost share funds to be refunded to their source.
Name of Facility O er (Please Print): �` l l • ��
Signature: _ f ; ti� /.'f
Name of Manager (If Different from Owtibr):
Signature:
Date: Q
Date:
Where owners of animal operations do not have adequate amounts of land to apply the waste, the producer must
provide a written agreement whereby another landowner has agreed to land apply or allow land application on
his or her land. The attached agreement may be used or some other documentation may be provided.
Adjacent Landowner Agreement
I, , understand that Mr./Mrs. does not have ample
land to apply the animal waste produced from his/her animal operation. I agree and give permission for
Mr./Mrs. to apply animal waste from his waste system on acres of
my land for the duration of time shown below.
I further understand that this waste contains nitrogen, phosphorous, potassium, and other nutrient elements and
when properly applied should not harm my land or crops. I also understand that the use of this waste will
reduce my need for commerical fertilizer.
Term of Agreement:
to
(Minimum of ten years on cost shared items)
(See specification No. 2)
Recipient Landowner (Please Print):
Signature:
Date:
10

elµ `WASTE TILIZATION aPLAN°. H ^
FOR SWINE OPERATION,w F,
r n •:� P { ar ,s r.1 k W �r t i; I �� r t"iy '"'1
�
Februairy 1,,20 '
Plan Approval
Name of Technical Specialist (Please Print): A6-my S - urr
Affiliation (Agency): c:�AZZU .SW c.0
Address: 100,0 , Avg A I
�A7 s✓ic.c.E ^/c- 27939
Signature: .5- att— Date: / -3/-0/
SWCD Board Review
S WCD Representative (Please Print):
Signature: G, / Date: 2� z Q,
11

U
'Pr
a
'IN* Moj5j; k
a

itilwo," X-4 55 ozo

ED STATES DEPAnTMENT OF AGRICULTURE __--�---- --� �_-
JRAL RESOURCES CONSERVATION SERVICE GATES COUNTY,
SOIL LEGEND
Map unit symbols and names are alphabolica), Map symbols aie' letlers or a combination of
letters and numbers. The first letter is Capitalized and Is ilia first letter of the series (or higher
level of classification) name. the second letter is lowercase. The third letter Is capitalized
and denotes the slope phase. Symbols with only two letters indicate soils that are named at a
category above the series level.
SYMBOL
NAME
Azle Alaga sand, 0 to 5 percent slopes
AIA Altavista fine sandy loam, 0 to 3 percent slopes
BaA
Ballahack loam, 0 to 2 percent slopes, occasionally flooded
BeA
Belhaven muck, 0 to 2 percent slopes
BnA
Bladen loam, 0 to 2 percent slopes
BOB
Bonneau loamy fine sand, 0 to 6 percent slopes
CIA
Cape Fear loam, 0 to 2 percent slopes
ChA
Chowan loam, 0 to 2 percent slopes, frequently flooded
COB
Conotoe line sand, 0 to 5 percent slopes
CrA
Craven fine sandy loam, 010 1 percent slopes
CrB
Craven line sandy loam, 1 to A percent slopes
CrC
Craven line sandy loam, A to 0 percent slopes
DoA Dorovan mucky peal, 0 to 2 percent slopes, frequently flooded
EKA
EMum silt loam, 0 to 2 percent slopes
GoA
Gofdsboro fine sandy loam, 0 to 3 percent slopes
1cA
Icaria fine sandy loam, 0 to 2 percent slopes
LeA
Lenoir loam, 0 to 2 percent slopes
LoA
Leon sand, 0 to 2 percent slopes
LyA
Lynchburg fine sandy loam, 0 to 2 percent slopes
NaA
Nawney loam. 0 to 2 percent slopes, frequently Ilooded
NoA
Noboco line sandy loam, 0 to 2 percent slopes
NOB
Noboca line sandy loam, 2 to 6 percent slopes
PaA
Pactolus s6nd, 0 to 3 percent slopes
PnA
Ponlego fine sandy loam, 0 to 2 percent slopes
PuA
Pungo muck, 0 to 2 percent slopes
RaA
Palms line sandy loam, 0 to 2 percent slopes
PoA
Roanoke loam, 0 to 2 percent slopes
StA
State line sandy loam, 0 to 2 percent slopes
SIB
State line sandy loam, 2 to 6 percent slopes
TaA
Tomahawk fine sand, 0 to 3 percent slopes
ToA
Tomotley line sandy loam, 0 10 2 percent slopes
Ud
Udorthents, loamy
Va8
Valhalla fine sand, 0 to 6 percent slopes
WnD
Winton fine sandy loam, 8 to 15 percent stopos
WnE
Winton line sandy loam, IS to 30 percent slopes

ATTACIU4ENT B
1 of
��orrh 1.a. olin.J .`i,'''!i !1lf:f''.1l �.1': �''I. � I j_ !'. ii i
Agr i�--Waste Man.a em ent
g
Biological and Agricultural Engineering North Carolina Stake University
LIVESTOCK HASTE SAHPLINO. ANALYSIS AND CALCULATION
OF LAND APPLICATION RATES
James C. Darker*
I. SAHPLE COLLECTION
A. Semi -Solid Lot Manure
L. Scraped directly from lot into spreader
a. From loaded spreader, collect about 2 lbs of manure from
different locations using nonmetallic collectors.
ii. From storage
a. Collect 'about 2 lbs of manure from under the surface crust
avoiding bedding materials and using nonmetallic collectors.
B. Liquid Manure Slurry
L. Under -slotted floor pit .
a. Extend a 1/2",nonmetallic conduit open on both ends into
manure to pit floor. �...,_
b. Seal upper end of conduit (s.g...by placing a thumb over end
of conduit) trapping manure thrt has entered lower and. remove
and empty slurry. into plastic bucket or nonmetallic container.
c. Take subsomples from'S or more locations or at least 1 quart.
d. Mix and add about 3/4 pint to notumetallic sample container.
iL. Exterior storage basin or tank
a. ?lake sure manure has been well mixed with a liquid manure
chopper -agitator pump''or propeller agitator.
b. Take subsamplis from about S pit locations, from agitator pump
or from manure spreader and place in a plastic bucket.
* Professor and Extension Specialist, Biological and Agricultural Engineering
Department. North Carolina State University, Raleigh, NC.

ATTACHMENT B '
2' of 3'
• C. nix and add 3/4 pint to a Nonmetallic sample container.
C. Lagoon Liquid
i. Collect about 3/4 pint orecycled lagoon liquid from inflow pipe
to flush tanks in a nonmetallic sample container.
ii. From lagoon
a. Place a small bottle (1/2 pint or lase) on end of 10-15' pole.
b. Extend bottle 10.15' away from bank edge.
c. Brush away floating scum or debris.
d. Submerge bottle within 1' of liquid surface.
e. Empty into a plastic bucket, repeat about 5 times around
lagoon, mix, and add 3/4 pint to nonmetallic sample container.
D. Broiler or Turkey Litter
I. House litter
a. Visually inspect litter for areas of varying quality. e.g..
areas around feeders and waterers, and estimate percent of
floor surface in each area.
b. Take about 5 litter subsamples at locations proportionate to
Item a. E.g., if 20% of litter of similar visual quality is
around feeders and waterers, take 1 subsample there and the
other 4 subsamples from remainder of floor surface.
c. At each location, collect litter from a 6" by 6" area down to
earth floor and place in a plastic bucket.
d. After 5 subsamples have been added to the bucket, mix, and add
about-2-3 lbs litter to a nonmetallic sample container such as
a t-gallon freezer bag and seat.
ii. From stockpile
a. Take subsamples from about 5 locations at least IS" into pile.
b. Mix, add 2-3 lbs to nonmetallic sample container and seal.

ATTACIIMENT 9
3 of 3
II. SAMPLE PREPARATION AND TRANSFER
A. Place sample into an expandable container that can be sealed. Rinse
residues from container with clean water but do not use disinfectants,
soaps, or treat in any other way.
B. Pack sample in ice, refrigerate, freeze, or transfer to lab quickly.
C. Nand -delivery is most reliable way of sample transfer.
D. If mailed, protect sample container with packing material such as
newspaper, box or package with wrapping paper, and tape.
E. Commercial sample containers and mailers are also available. Contacts:
i. A&L Eastern Agricultural Lab. Inc. iii. Poiyfoom Packers Corp.
7621 Whitepine Road 2320 S. Foster Avenue
Richmond, VA 23237 Wheeling. IL 60090
Ph: [phone] Ph: [phone]
ii. Fisher Scientific Co. iv. NASCO
3315 Winton Road 901 Janesville Avenue
Raleigh,.NC 27604 Fort Atkinson, WI 53538
Ph: [phone] Ph: [phone]
F. Private analytical labs are available, but sample analyses are costly.
C. The NCDA provides this service for North Carolina residents.
1. Address: North Carolina Department of Agriculture
Agronomic Division
Plant/Waste/Solution Advisory Section
Blue Ridge Road Center
P.O. Box 27647
Raleigh, NC 27611
Ph: [phone]
Attn: Dr. Ray Campbell
ii. Forward $4 along with the sample.
iii. Include the following identification -information with sample:
a. Livestock species.(datry. swine, turkey, etc.)
b. Livestock usage (swine -nursery, finishing; turkey -breeders,
brooderhouse, grower, number flocks grown on litter; etc.)
c. Waste type (dairy -lot -scraped manure, liquid slurry; swine -pit
slurry, lagoon liquid, sludge; broiler -house litter, stockpile
iv. Routine analyses performed on all samples: N, P. K, Ca, Mg. Na,
S. Fe, Mn. Zn, Cu, 8
v. Additional analyses performed upon request: DH, Ho, Cd, Ni, Pb

0
4�'84.0/007&7
92/
m0a-dV-
$1#," 0 S
00
v1
T4490
oy?!
-4P/.12PP-,e V of
F)U-V--.1J0jLAC) At-C-LlCj-l!5tAodsa-t .3k4'j , SI: Lj '-jUE-1WF')6VLP&jj
..10 kA1.'3tS1A'1('1 1:3LAt?
jx) S tEj1 -?rA O.I.L.11 j.a ab-tek.ps-cp aq-1 s-j-!(j,!,L4Q-td j,a t..tea-j-,7 a k' jj.
ia6u)-v I T I 1.? 41? a L1.1 1 M POJO/NOD OCI
5511)..) 5I..qT"j1")PE)k atk.k136U''61L.t.('1: i.3.1t.I�E-If:: M1)f CICII.I.S SID'I T 0' 1a1( II
T t? I (A I C3 t.14 J. 1.) U C.) I 'I k:'y -.t'j t'k tj ::rLt 0 D F) kLj' SL a n I -I pa I I':A - I -I s
(_3U I f) -i -10 p 0 B A T S S B D X fJ 'j L q F-) A UJ- k d -1) .1 A D V? d e :3 s: I- o -.1 Ea b-t V? L 1 :3
J d D C1 LA 0 C? I.") V LI E) w I t? a -t -j 0. t-I -1 f} V.? I. I -'j p a p U 0 Lo Lo a :j a -t Al b Lt c) -t s s:
- 5, a q I- ...q I.-) 43 I. L I ii3 to Ili a '--D a 1 0 .1. s S'
pal Tdtiv! s-r aswm
k? I -I u k. t I? a 1.) e tA) a cl ILI f -c I --. -c -( d d v? � c P8-te Z3LI.1 j) . �.5 Sj
3LIS uo . eo _ .1 � I Ell
Bj:)/,-) LA 01 '1 N7 D 'k CJ d e LI-DY-1cJ E-) A C-) j a c I
A V? t1 Va C.3 -1.) o..s I-t ('.0�kt..1 o I qI? (] de t..t .-t O..C.F� C. BjJ?L. ? jC.
f, ul a Ili -D v., a z) 55 O'l s IP M Q F) U 1 .1 0-1 ID LA tF) U T T dwvs s p t-t a u) Ili c; a-t i.ve ri
c t.1 i Pt -WO'( TIDJ f-)Cl P13*1014S Lke'IAJ � 1, k Z-3 LU Z-) b P U A? W i3 IS P M f) E-3 Ll :3 V .4 -.} e i3 L.I.]
t-1 o 1: -[ 'E? A c3 'r Ei 50 LI D V J I DA3 I -L 11 j ED Lj I LJOLIM
5 C-3 I. e to cv.I. 'Z3 p.tauew-t�,,3(-J Ac�j S-5v? 91(" S LL 13 T .1 F A E-3 'I' E3 S, %) Lj D V? 0--t
1 E3 p.rill .1. LAE)t4M U Q 0 b Y.? I a L 1,1 jr) '}fu,)-dulnd Lvibaej 9L.IjkJ0U.1,,#2n A..tata
pj.3duir1d aq cil pcient '(j'!m b -,-ko-Vs
E."AIL'?p ..taj. k,A C,) I V? A 0 Cl P A E.3 E-'-; 5:': E-1 D X EA
I -1- -1 v -I J--j uq e '�JAV3-AB I V? i'i3 e u7 v?j. u T v'? -t
JO 'JAMIQUIV? -3 )C? r.) Qj? I JOAO F)ftSVtA J.0 i:3UMT. C)A &U1.1 A C').'j,
Aq 6 �--? -I- a k-I'l J. o t' t o E I -.t ID d a b e a 'I s A - k e --t to a 'I. a
- fl. L I C.") 10 M F-1 A I 1 .4.1'3 PIA1,10CI j cj Q. 0 Oj .-:) I
1.t b V? "A C) ,15 f� t' I a k-t �? (j) -.k a CA p YI -f. ..) t ( -rL R-0--)1sap ..A V) D G T T M U "D "I -D V?
C) 1. .
'J I C.1 0 A EA? LA 'E' L.1 i.-D-AiISFUZ-�1 0'� A i�j p A 0 LA I [D7dWild c.)Uj OfOU iL--, I &) v? J 0 q s
LA c:) U V? U) tHd EAJ_I_ I:M-1�? 4LUBLIY?WAi)d k.1-JOCI S U V? I kJ Q -3
S': 't V Ili I U V� / S M 1,'.) E.--,
I Q -1 Y? A 0.:p C-) Ut f.-'3 'I S a 17') s e m A -I- vj- q I ..k i ki c-) b I? I.. k V.? t 1) a '.J. Et e m w w 1A P k 1")
k..t o -r -1. 1, -.t is crc- - }-'(

Producer: J
____��________________________
The
purpose of this
plan
is to provide
guidelines for carrying out
the
routine operation
and
maintenance work
needed to keep this swine
waste
management system
functioning
as
planned. Routine maintenance
is
considered to be
normal
good care of
the system. Good
maintenance
adds to
beauty,
usefulness,
and permanence.
A. Maintenance
The routine maintenance of the lagoon involves the following:
1. Maintenance of a vegetative cover on the embankment top and
side slopes. 4- g -___________________ is
being established on these areas. Beginning in 19pg amd
each year thereafter, the embankment should be fertilized
with 800 pounds of 10-10-10 per acre to maintain a vigorous
stand.
2. Control of brush and trees on the embankment. This may be
done by mowing, spraying, or chopping, or a combination of
all three. This will need to be done at least once each
year and possibly twice in years favorable to heavy growth
of vegetation.
Maintenance inspections of the lagoon should be made during the
initial filling of the lagoon and at least annually. Items to
be chocked should include, as a minimum, the following:
1. Waste Inlet Pipes, Overflow Pipes
a. condition of pipes
(1) separation of joints
(2) cracks or breaks.
R. Pool Area
a. undesirable vegetative growth
b. floating or lodged debris
3. Embankment
a. settlementi cracking or "jug" holes
b. side slope stability - slumps or bulges
C. erosion and rodent damage
4. Transfer Pump

EMERGENCY ACTION PLAN
PHON-E NUMBERS
DWQ 9�V6T 6'YR
EMERGENCY NIANAGEME T SYSTEM 9/1
SWCD _912-397-1991 - - - ---
N-RCS 919- 3s7- ig9t
T'rtis plan will be implemented in the event that wastes from your operation are leaking,
overflowing, or running off site. You should not wait until wastes reach surface waters or
leave vour property to consider that you have a problem. You should make even, effort to
ensure that this does not happen. This plan should be posted in an accessible Iocation for
all employees at the facility. The following are some action items you should take.
L Stop the release of wastes. Depending on the situation. this may or may not be
possible. Suggested responses to some possible problems are listed befow.
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B: Runoff from waste application field -actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that caused the runoff.
e. EvaIuate the application rates for the fields where runoff occurred.
I
C: Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
d. , Repair all leaks Frior to restarting pumps.
D: Leakas*e from flush systems. houses. solid separator, -action include:
a. Stoprecycle pump.
b. Stop irri_ation pump.
c. %lake sure no siphon occurs.
d. Stop all tlokv.; in the Douse. 11u:=h systems. or :ciid separators.

e. Repair all leaks prior to restarting pumps.
E: Leakage from base or sidewall of lagoon. Often this is seepage as opposed to
flowing leaks- possible action:
a. Dig a small sump or ditch away from the embankment to catch all seepage,
put in a submersible pump, and pump back to lagoon.
b. If holes are caused by burrowing animals. trap or remove animals and ftil
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon
bottom as soon as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what duration?
c. Anv damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f.. Could a future rain event cause the spill to reach surface waters?
s. Are potable water wells in danger (either on or off of the property)?
h. How, much reached surface waters?
3: Contact appropriate agencies.
a. During normal business hours call your DWQ (Division of Water Quality)
regional office; Phone0950 il/ After hours, emergency number: 919-733-3942.
Your phone call should include: your name, facility, telephone number, the details
of the incident from item 2 above, the exact location of the facility, the location or
direction of movement of the spill, weather and wind conditions. The corrective
measures that have been under taken, and the seriousness of the situation.
b. If spill leaves property or enters surface waters, call local EMS Phone number
c. Instruct EMS to contact local Health Department.
d. Contact CES, phone numberf'lfj�'9e0 local SWCD office phone number�''� -
and local NRCS office for advice/technical assistance phone numberOfP4r-z /�2/
4: If none of the above works call 911 or the Sheriffs Department and explain your
problem to them and ask: that person to contact the proper agencies for you.
5: Contact the contractor of your choice to begin repair of problem to minimize off -site
damage. -
a. Contractors Name: . &&CAT' 111AffO&I
b. Contractors Address: JNTdN• . C
c. Contractors Phone: fif-JSS- LZ� /

6: Contact the technical specialist who certified the la-oon (MRCS. Consulting
Engineer. etc.)
a. Name:__f 9,LVVA5 07F
I �1_.
b. Phone: 9 -Jr-J r7-- /881
7: Impiernent procedures as advised by DWWQ and technical assistance agencies to
rectify the damage. repair the s}stem, and reassess the waste management plan to
Keep problems with release of wastes from happening again.
Dccenire- 1`�. 1�96

Mortality Management 1-Iethods
(check which method(s) are being implemented)
aef Burial three feet beneath the surface of the ground within 24 hours after
knowledge of the death. The burial must be at least 300 feet from any flowing
stream or public body of water. 4
ED Rendering at a rendering plant licensed under G.S. 106-168.7
❑ . Complete incineration
❑ In the case of dead poultry only. placing in a disposal pit of a size and design
approved by the Department of Agriculture
❑ Anv method which in the professional opinion of the State Veterinarian would
make possible the salvage of part of a dead animal's value without endangering
human or animal health. (Written approval of the State Veterinarian must be
attached)
L,�.ernb� Is, 1996

Swine Farm Waste Management Odor Control Checklist
Source Cause UMl's to Miaintim Odor Site specific Prarticcs
annstead • Swine production ❑ Vegetative or wooded buffers;
❑ Recommended best management practices;
l"Good judgment and common sense
Animal body surfaces • Dirty manure -covered animals Dry floors
How surfaces Wet manure -covered floors Slotted floors;
W Waterers located over slotted floors;
GY" Feeders at high end of solid floors;
❑ Scrape manure buildup from floors;
9""Underfloor ventilation for drying
ALunsrc cullcc6011 hits • Urine; ❑ Frequent manure removal by flush, pit recharge,
• Panial microbial decomposition or scrape;
❑ Underflnor ventilation
VLIYtilatiolk exhaust falls • Volatile bases; Fan maintenance;
Dust ❑ Efficient air movement
haloor surfaces Dust FR' Washdown between groups of animals;
❑ reed additives;
❑ feeder covers;
❑ Fced delivery downspout extenders to feeder
covers
1=1u�1s tauLs. Agitation of recycled lagoou 0 Flusli tank covers;
liquid while tanks are filling ❑ Extend Fill lines to near bottom of tanks with
anti-siplion vents
Fls1slt alleys • Agitation during wasiewater Underfloor flush with underfloor ventilation
conveyance
1'is iech:nge points Agitation of recycled lagoon 0 Exiend recharge lines io near, buttutn of pits
liquid while pits are rlling with anti -siphon vents
Lift stations • Agitation during sump tank 0 Sump tank covers
filling and drawdown
outside drain collection • Agitation during wastewater ❑ Box covers
Ur junction boxes cUttvCyatice
AN10C - Nuversber 11. 1996, Yale 3

Source Cause RMPs to Minimize Odor Silt Specific Practices
End of drainpipes at • Agitation during wastewater 0 Extend discharge point of pipes underneath
lagoon conveyance lagoon liquid level .
Lagoon surfaces •' Volatile gas emissions; C-Proper lagoon liquid capacity; — - — --
• Biological mixing; ❑ Correct lagoon startup procedures;
• Agitation Cl Minimum surface area-to-volunte ratio;
Cl Minimum agitation when.pumping;
0 Mechanical aeration;
Cl Proven biological additives
Irrigation sprinkler a l Iigh pressure agitation; R' Irrigate on dry days with little or no wind;
uoccies 0 Wind drift I311"�Minimum recommended operating pressure;
f3"' Pump intake near lagoon liquid surface,
Lir---Purnp from second -stage lagoon
St{,rage tallk Or Gasill • Partial microbial ciccnlnposilion; ❑ lInttom or midlevel loading;
"" I'a a 0 Mixing while filling; ❑' Tank covers; f
• Agitation when emptying ❑ Basin surface mats of solids;
❑
Proven biological additives or oxidants
Seulilrg basin surl:rce
Partial rnizrubial decomposition;
❑
Extend drainpipe outlets underneath liquid
•
Mixing while felling;
level;
•
Agitation when emptying
0
Remove settled solids regularly
Manurc, slurry or sludge
Agitation when spreading;
❑
Soil injection of slurry/sludges;
spreader outlets
Volatile gas emissions
0
Wash residual manure from spreader after use;
CI -
Proven biological additives or oxidants
I Jacovered manure,
Volatile gas emissions while
❑.
Soil injection of slurry/sludges
slurry or sludge on field
drying
13
Soil incorporation within 48 Jim.;
surfaces
❑
Spread in thin uniform layers for rapid drying;
❑
Proven biological additivcs or oxidants
Dead auinlals •
Carcass decomposition
Proper disposition or carcasses
Dead animal disposal •
Carcass decomposition
0
Complete covering of carcasses in burial piss;
pits
❑
Proper local ion/constntction of,disposal pits
luciuclamis •
Incomplete combustion
CI
Secondary stack burners
AMOC eniber 11, 1996, Page 4

Source Cause BMPs to Minimize Odor Site Specific Practices
Staaading water around • Improper drainage; Grade and landscape such that water drains _
facilities Microbial decomposition of away from facilities
organic matter
Manure tracked onto • Poorly maintained access roads O Farm access road maintenance
public roads from faun
.access
Additional information: -
Swine Manure Management ; 0200 Rule/BMP Packet
S%vine Production Farm Potential Odor Sources and Remedies ; EBAE Fact Sheet
Swine Production Facility Manure Management: Pit Recharge - Lagoon Treatment; EBAE 128-88
Swine Production Facility Manure Management: Underfloor Flush - Lagoon Treatment; EBAE 129-88
Lagoon Design and Management for Livestock Manure Treatment and Storage ; EBAE 103-83
Catihration of Manure and Wastewater Application Equipment; EBAE Fact She ct
('outiolling (odors from Swine Buildings ; 1111-33
E'iwiron,ncneal Assursnee Program ; NPiIC Manual
Options for Managing Odor; a report from the Swine Odor Task Force
Nuisance Gonccros in Animal Mannr:: Management: Odors and Flies; Pit 0107, 1995 Conference Proceedings
Available From :
NCSU, County Extension Center
NCSU - BAE
NCSU - BAE
NCSU - BAE
NCSU - IIAI:
NCSII - BA1:
NCSI! - Swine: Extension
NC Purl: Producers Assoc'
NCSU Agri Communications
Florida Cooperwive Extension
Ak40(: - 14ov0111mi 11, 1996. I ;age: 5

Insect Control Checklist for Animal Operations
Santee - Cause HMI's to Control Insects --- - Situ Specific Practices -- —
Liquid Systems
Flush Outlets Accumulation of solids Flush system is designed and operaled
sufficiently to remove accumulated solids front
gutters as designed.
D Remove bridging of accumulated solids at
discharge
Lagoluss and fits • Crissled Solids Maintain lagoons, sellling basins and pits where
pest breeding is apparent to minimize the
crusting of solids to a depth of no more than 6 -
8 inches over more than 30% of surface.
Excessive VCgCtalivc Decaying vegetation lr Maintain vegeialive control along banks of
t iru,vth lagoons and other impoundments to prevent
accuamtlauon of decaying vegetative matter r
along waives cadge on impoundment's perimeter.
r,ry Systems
�FccJc,: Feed Spillage n D►sign, operate and maimain feed systems (e.g..
bunkers and troughs) to minimize the
accumulation of decaying wastage.
0 Clean up spillage on a routine basis (e.g., 7 - 10
clay interval eluting summer; 15-30 day interval
during winter).
Feed 5wtage Accumulallons of feed residues D Reduce moisture accumulation within and
:around inimediale perimeter of feed storage
areas by insuring drainage away from situ
and/or providing adcqualc canlaiuurcnt (e_b.,
covered bin for brewer's grain and similar high
moisture grain producls).
C1 Inspect fur and remove or break- up acaunislated
solids in tiller strips arum id Iced slur;age as
needed.
Ahtlt' - Muvcual►er 11, 11196, Page I

Snurec Cause
BMPs to Control Insects Site Specific. [Ira clices
Animal Holding Areas Accumulations of animal wastes
❑
Eliminate low areas that trap moisture along _
anti feed wastage
fences and other locations where waste
accumulates and disturbance by animals is
minimal.
0
Maintain fence rows and filter strips around
animal Bolding areas to minimize:
accumulations of wastes (i.e., inspect for and
remove or break tip accumulated solids as
needed).
Dry Manure I land ing Accumulations of animal wastes
❑
[remove spillage on a routine basis (e.g., 7 - 10
Sps[cins
day interval during summer; 15-30 clay interval
during; winter) where manure is loaded for land
application or disposal.
❑
Provide for adequate drainage around manure
stockpiles.
L1
Inspect for and remove or !teak up accunnilaied
wastes in filter strips around stockpiles and
inanure handling areas as needed.
For enure iol'Onnation contact the Cooperative Extension Service, Department of Enlontology, Box 7613, North Carolina Stale University,
Raleigh, NC', 27695-7613.
A A I c ; - Ter 11, 1996, Vage ?

2/12/96
Producer: �'A V L L QL E Y
Q/ 1. scaled drawing of the proposed irrigation system including
hydrant locations, travel lanes, pipeline routes, thrust
block locations and buffer areas where applicable.
2. Itemized quote from irrigation dealer.
3. Waste Utilization Plan and maps.
4. Manufacturer's specifications for the irrigation pump,
traveler and sprinkler(s).
5. Manufacturer's materials and installation specifications for
the pipe and/or USDA-NRCS standard for Irrigation Water
Conveyance, N.C. Field Office Technical Guide, Section IV,
Practice Code 430-DD.
6. Irrigation System Design Parameters Worksheet to be filled
out in its entirety.
Table 1 - Field Specifications (to be filled out by Field
office personnel)
Table 2 - Traveling Irrigation Gun Settings
spacing of hydrants should be computed as 70% - 75% of the
wetted diameter. For normal wind conditions above 5 mph,
spacing of 50% to 55% should be used.
Irrigation dealer to provide sources and/or calculations
used for determining application rates.
Traveler Application Rate computed as:•
I= [(96.3 x q)/(3.14 x (0.9 x r)2)] x 360/w
where,
I " approximate actual application rate (iph)
q = discharge (gpm)
r = wetted radius (ft)
w = portion of circle receiving water (degrees)
Total application amount for the given travel speed and
lane spacing should be below the maximum allowable
application amount for the crop and soil type shown in the
Sprinkler Irrigation Guide and under the maximum allowable
nutrients to be applied.
0

Application Amount computed as:
d = (1.605 x q]/[l x s]
where, N
d = gross application (in)
q = sprinkler discharge (gpm)
1 = travel lane spacing (ft)
s = travel speed (fpm)
Table 3 - Solid Set Irrigation Gun Settings
Spacing of risers along the main and lateral lines should
be computed as 60% of the wetted diameter.
Irrigation dealer to provide sources and/or calculations
used for determining application rates
Solid Set application rate computed as:
I = (96.3 x q]/(sl x sm] x 360/w
I = average application rate (iph)
q = sprinkler discharge (gpm)
sl = spacing of sprinklers along the laterals (ft)
sm = spacing of sprinklers along the mainline (ft)
Total application amount for the given operating
time should be below the maximum allowable
application amount for the crop and soil type as
shown in the Sprinkler Irrigation Guide.
Computations used to determine the size of thrust blocks
and illustrations of all thrust block configurations
required in the system.
Thrust blocks sized according to:
Thrust block area (ft 2)= W = Thrust
F Soil bearing strength
Soil bearing strength of 1200 - 2000 psf should be used.
Computations used to determine all mainline and lateral
pipeline sizes. Maximum flow velocity must be kept below
5 fps.

Velocity in a pipeline calculated by:
v = (0.408 x q]/d 2
where,
v = velocity of water (fps)
q = flow rate (gpm)
d = inside diameter of pipe (in.)
Assumptions and computations for determining total dynamic
head and horsepower requirements. Charts may be used for
head loss in pipelines, etc. but the charts should be
included in the packet. The dynamic head (TDH) should
.include as a minimum the following components:
-- elevation difference from waste water to nozzle
-- friction loss in pump
- friction loss in pipeline
- friction loss from fittings and misc.
- sprinkler discharge pressure
Required system operating pressure must be less than the
available working pressure. one foot of water is equivalent
to a pressure of 0.433 pounds per square inch. The pump
performance curve must meet the design requirements for Q
(total for all sprinklers to be run at one time), TDH, and
BHP.
Brake horsepower computed as :
BHP = [ Q k TDH]/[3960 x Ep]
where,
BHP = power required to drive the pump (hp)
Q = flow rate (gpm)
TDH = total head the pump operates against (ft)
Ep = pump efficiency (decimal form)
✓/. Narrative of system operation to include start-up, shut --down,
and winterization procedures and regular maintenance of all
equipment.
yV8� Waste Utilization Plan should show all areas receiving
coverage from the irrigation system. As a minimum the
acreage shown should be the area receiving uniform coverage
under the irrigation system.
Reviewed by: Date:
Approved by: Date: D

IRRIGATION PARAMETERS FOR ANIMAL WASTE MANAGEMENT SYSTEMS
Landowner/OperatorNamc: car. l-f Date_ /o : 2,6
Address: Pf a? fP-, e x /%
�-±A,! _ v A!--tr TALC Q 7 �% 3
Telephone: 091 ? 517 - Q S 1)5 _
TABLE 1: Field Specifications
Field
Numbers
Approminate
Maximum
Usable Sire
of Field`
(ac)
Soil Type
Slope
(°/u) I
Crop(s)
Maximum
Application
Rate
(in/hr)
Maximum
Application
per irrigation
Cycle
(in)
Comments
5
I
T o�
/
Cor• n
/•o
1 Table to be completed in its entirety by Field Office Personnel in accordance with the Field Office Technical Guide and fonvarded to the irrigation system
designer. /�yN6�-3 IKAe A 73;
3 See attached map provided by the Field Office for field location(s). C"
Total Field acreage minus required buffer areas.
4 Refer to North Carolina Irrigation Guide in Section 11G of the Field Office Technical Guide. Do not exceed nutrient loading rates
IRRIGATION PARAMETERS I USDA-NP-- / •!JZ
Se, ^r 25, 1995 Nor -tit Cz

TABLE 2: Traveling Irrigation Gun Settings NC'L ON 15o S-01,;0S
Make, Model and Typo of Equipmenl:A6l r 10307 ?er l.40 r % f o PT v f urr j 1-1 ~
Field No`
:and
Hydrant Nu`'
'travel Applicalion TRAVEL LANE
Speed Rate Effective 12116clive
(fllmin) (itt/hr) Width(ft) Length(R)
Welled
Dianseter
(ft)
E
Nozzle
Diametcr
(in)
UIPMEN'I' SETTINGS
01',cratiu9 Operating
Pressure Pressure
0,) Gun (psi) (a; Recl (psi)
Arc
Pattern'
Comments
r
S
.03
� �
��
%dD �
3�a v
'
7 C ✓
JoS
3pO
2zy-
8do"
3215
Sao
s 3
�.c3
74Y
774 -
o00
f'�)
r
S Sec attached map provided by the Field Oboe for -field locatiort(s).
6 Show separate entries for each hydrant location in each field.
' Degree or Arc.
IRRIGATION PARAMETERS 2 USDA-NR r`-
Se- '-er 25, 1995 North G

TALE 3: Solid Set Irrigation Gun Settings
Make, Model and 717
1 of Equipment:
Field Nos 7�lic.�tion
and Number of �2ktc
Line Ne Hydrants (in/hr
I1 �drant Spacing ❑
Along Bctween
Pipeline Pipelines
E UIPMENT SETTINGS
Wetted No:/Ac Oteerating Operating
Diameter Diameter Pressure Time Arc
(ft) (in) r; Gun (psi 01 Tlydrant (hr) Pattern' Comments
a See attached map provided by the Field Office for -field location(s).
9 Show separate entries for each hydrant location in each field.
10 Degree of Arc.
IRRIGATION PARAMETERS 3 USDA-NRrc
Ser' - -,ber 25, 1995 North Q

TABLE 4: Irrigation System Specifications
rave ng
Irrigation Gun
Solid Set
Irrigation
Flow Rate of Sprinkler (gpm) /q ?
Operating PFCSSure at Pump (psi) I.?
Design Precipitation Efate (inlhr) .3�1g
hose Length (n) $
xxxxx xx
Type of Speed Compensation � r �� � �
XXXXXXXX
Pump Type (PTO, Engine, Electric) PTO
-Pump Power Requirement (hp) it
2Z.9
TABLE 5: Thrust Block Specifications"
LOCATION
THRUST BLOCK
AREA (r�-r)
900 Bend
WA
Dead End
A
Toe
A
Other
Oilier
�I u, ?:de -
NOTE:
A buffer strip 50 feet wide or wider must be maintained between the limits of the irrigation system and all perennial streams and surface waters per
DEIINR-DEM Code, Section 15A NCAC 2D .0200 - Waste Not Discharged to Surface Waters.
" See USDA-NRCS Technical Guide, Section IV, Code 430-DD.
IRRIGATION PARAMETERS 4 USDA-NRt"S
Scps—fiber 25, 1995 North C.

Narrative of Irrigation System Operation
Briefly describe operation of the system in the space provided below. Include procedures such as start-up, shut -down, winterization
and regular maintenance_
IRRIGATION PARAMETERS 5 USDA-NRCS
Ser' -•ber 25, 1995 North Cr

IRRIGATION SYSTEM DESIGNER:
Name: U4RV AJ. IVAAINiAlG
Company: _ ?eve/l,,
Address: jd .? WPs Ar,
,/,�t ers t ve o ,-AJC n77 005S_
Telephone: 7 tg — .-3b
REQUIRED INFORMATION
The following information and computations must accompany all irrigation designs for review:
1. A scale drawing of the proposed irrigation system which includes hydrant locations, travel lanes, pipeline routes, thrust block
locations, and bufTer areas where applicable.
2. Specifications for the irrigation pump, traveler, and sprinkler(s).
3. Computations used to determine all mainline and lateral pipe sizes.
4. Total Dynamic Head computations and Horsepower requirements.
5. Sources and/or calculations used for determining application rates.
G. Computations used to determine the size of thrust blocks.
7. Manufacturer's specifications for the irrigation pipe and/or USDA-NRCS specification for Irrigation Water Conveyance, Technical
Guide, Section IV, Code 430-13D.
IRRIGATION PARAWMRS 6 USDA-NRCS
September 25, 1995 North Car -"-a -

Narrative'of Irrigation System Operation
Describe the operation of the system in the space provided
below or on a similar sheet most .convenient to .the
designer/supplier.
Include procedures such as start --up, shut -down, winterization
and regular maintenance of all equipment.
This irrigtor is designed to apply of water at specified
ratings. Pump should be primed and started and 1030
traveling hose should be extended to specified destinations -
in accordance with map. The reel should be started in manner
that is given in owner's manual that accompanies the machine.
The machine is equipped with shutoff system, so there is
no harm done to the machine itself. The irrigator should
only be ran in accordance with the waste management plans
and to the specifications of this design.
winterization should be done when the machine will be shut
down for more than a month at a time, during the winter
season. All water should be drained and machine should
be greased and oiled.
Regular checks should be made on the reel, hose, and all
mechanical equipment on the machine itself.

v e,L
nix/� 7z6
Lj�� �o•� J .rPICT1A.?IIO- S.0aJ,�+
F�•n� re* pQF �o-)/ )e x p r
_ r
[ 6 /� 5 0 � = o 9 F e.61 X
c.s p6
xog to t cv
"°d

Ars a. s- L
K d /00
T, *2 //�oo
-
(
a/c, v —el,.
/77
cl?
V3 3
. ..... . . .....
A. TS 3
Iv. v 1 -3

70ps, t 35 = a S r"
v[t �p✓� - g• eao
0
7
//9.z9
e/oar��!
' Yoe�—
:3 s-
� -� A

owl
�V(
i"M
.1
Z;�; A -
;"t' j
&LAM
m
F.
Jr

. ' . RECEIVED Nov o t 1995
._._. �-
T UNITED STATES Natural County Agriculture Building
DEPARTMENT OF Resources 403 Government Circle, Suite 4
AGRICULTURE Conservation Greenville, NC 27834
Service Phone: [phone]
SUBJECT: Paul Lilley Date: October 30, 1996
Waste Irrigation system
To: Mark F. Pollard
Soil Conservation Technician
P. O. Box 61
Gatesville, NC 27938-0061
Enclosed please find the design for Paul Lilley Waste Irrigation
System. I have reviewed the information submitted to me and the
plan is approved subject to a minor correction on the pump
horsepower. I made the correction on the design.
once the system is installed, a letter of certification is needed
from the irrigation installer confirming the system has"beeh
pressure tested'and has'been.installed according'to MRCS"
standards and specifications.' -.You are encourage to make one
field visit during installation. Approval for cost share will be
based on this certification.
If I can be of other assistance please don't hesitate to give me
a call.
Claude M. Long
Civil Engineering Technician
cc: Gary W. Manning
G. Douglas Jones
Joy Sherrod
r

it1,VELLE AGRI PRODUCTS, INC.
P.O. BOX 68
508 WEST nROAD STREET
MURFREESBORO. NORTH CAROLINA 27855
TELEPHONE [phone]
November 4,1996
Mark F. Pollard
Soil Conservation Technician
PO Box 61
-Gatesville, NC 27938-0061
Dear Sirs:
The Hobbs 1030 Hard Hose Traveler, Ravotti PTO Pump, and 6" Aluminum Pipe has
been delivered and set in place at Mr. Paul Lilley's in Gatesville, NC. This equipment and
design meets all design and installation specifications set forth by our design group at
Revelle Agri -Products. This layout is in accordance with the plan approved by Mr.
Claude Long, Civil Engineering Technician, of the NRCS office in Greenville, NC.
My own crews delivered the pipe, and equipment to farm, and made inspections of all of
the equipment before leaving the site.
At the delivery, Mr. Lilley was provided with information on how to operate, maintain;
and service the irrigation equipment our office provided him with. We have laid out an
irrigation plan that meets all North Carolina laws, and if properly followed will apply the
specified amount of water. All pressures, running times, and specifications in the plan
must be followed to meet approval.
If you have any questions or need anything else please call me at [phone].
Sincerely;
�J W .
Ga W. 0 1
annin
rY la
Irrigation Designer
Revelle Agri -Products, INC.

�0� w A r�RP
�O G�
c r
Paul Lilley
Paul Lilley Farm
145 NC 37 South
Gatesville NC 27938
Dear Donald Register:
0
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
August 22, 2003
Alan W. Klimek, P.E., Director
Division of Water Quality
AUG 2 6 2003
DWQ-WARO
Subject: Application No. AWS370015
Additional Information Request
Paul Lilley Farm
Animal Waste Operation
Gates County
The Non -Discharge Permitting Unit has completed a preliminary review of the subject application. Additional
information is required before we can continue our review. Please address the following by September 22, 2003:
Please include in the Waste Utilization Plan Narrative a description of the 70 swine on ground.
Also, include the enclosed General Guidelines for Swine on Dry Lots.
Please note that all WUP revisions must be signed and dated by both the owner and the technical specialist.
Please reference the subject permit application number when providing the requested information. All
information should be signed, seated, and submitted in duplicate to my attention at the address below. The
information requested by this letter must be submitted on or before September 22, 2003 or the Division will return
your application as incomplete in accordance with 15A N.C.A.C. 2H .0200 and your facility will be considered to
be operating without a permit.
Please be advised that operation of the subject animal waste management system without a valid permit is a
violation of North Carolina General Statute 143-215.1 and will subject you to the enforcement authority of the
Environmental Management Commission.
If you have any questions regarding this request, please call me at [phone], extension 544.
cc: ',Wa`slungtonRUgional_Officn,_W ater-QUality�
Permit File
Dennis Utt, SWCD
Non -Discharge Permitting Unit
1617 Mail Service Center, Raleigh, NC 27699.1617
DENR Customer Service Center
An Equal Opportunity Action Employer
Sincerely,
Y///,/z IL -0, 41 6
Michelle McKay
Environmental Engineer
Non -Discharge Permitting Unit
Internet http://h2o.enr.nc.state.us/ndpu
Telephone [phone] Fax [phone]
Telephone [phone]
50% recycled/10% post -consumer paper
tJ []ENR

GENERAL GUIDELINES FOR SWINE ON DRY LOTS
(Revised july 23, 1°°' November 5, 1997)
Runoff control: Surface runoff from outside the dry lot must be diverted away from the
dry lot. Efforts should be made to prevent runoff from leaving the dry lot from storms less
severe than the 25-year, 24-hour storm event.
Buffer: : Hogs must be located as far as practical from swamps and
streams. A minimum of a 10 feet of buffer must be maintained between the
dry lots and upslope stream ponds, swamps and ditches. A minimum of a
100 feet of buffe -giltpr- must be maintained between the dry lots and down slope
streams, ponds, swamps and ditches. Buffers must be vegetated and protected b y
a fence. . Spreader diversions must
be used as needed to insure sheet flow. 3Azttere a Ion CA(;t-€i-Iter MAP eannet be
n-st--alled— t0he 1-i-se of a diversion or. other- required to gain at le
Where design and implementation of a _100-foot buffer _is not physically
tactical other water guality protection measures or combinations of
measures may be installed if this measures rovide at least at a minimum
the same nutrient and sediment protection _ as a 100-foot buffer (e.g..
diversion to a filter strip area). For each inch of runoff which can be safely
stored within the dry lot. the width of the buffer can be reduced by 20 feet.
However the buffer must never be less that 20 feet. Buffers will not be
located where the ground surface is seasonally flooded.
3. Soils: Efforts must be made to avoid soils that have a high leaching potential and those that
are highly erodible. Animals will not be Iocated where the _ground surface is
seasonally flooded.
4. Rotation: Hogs must be rotated using a minimum of two lots. The maximum amount of
time for hogs to be on a single lot is one year. The amount of time off the lot must be
sufficient for vegetation to approach maturity to maximize nutrient uptake.
5. Crops: The crop grown on a site must be harvested or grazed. A uniform stand of
vegetation must be reestablished within 30 days from the time that animals are removed.
Land smoothing may be required prior to seedbed preparation. The crop may be trees
recommended to maintain compliance with the Federal Farm Bill.

t7 Nq=�w 11C
Michael F. Easley, Governor
William G. Ross Jr., Secretary .
North Carolina Department of Environment and Natural Resources
Janua%13, �003
R.ECEMILF0
Alan W. Klimek, P. E., Director
Division of water Quality
Paul Lilley Facility Number 37 - 15
Paul Lilley Farm JAN 14 2003
146 NC 37 South
Gatesville INC 27938
DWQ-WAR4
Subject: Public Meetings for Draft Renewal of State Non -Discharge Animal Waste Operation General
Permits
Dear Producer:
Your animal waste management facility is scheduled to be issued coverage under the Animal Waste
Operation General Permits in the near future. The Division of Water Quality (Division) staff is currently
in the process of renewing the Animal Waste Operation General Permits and is scheduled to have the
permit reissued by early April 2003. Once the permit is reissued, your facility would be eligible for
coverage under the reissued permit.
The Division has published a public notice regarding these renewed general permits. A copy of
the draft animal waste operation general permits and fact sheets are available at the website
hftp://h2o.enr.state.nc.us/ndpu/
or by writing or calling:
Non -Discharge Permitting Unit
NC Division of Water Quality
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
Telephone number: [phone], ext. 574
The Division will be conducting public meetings regarding these renewed permits. The following is a
list of dates, times, and locations of the public meetings:
February 3, 2003; 7-9 p.m.; Kenansville — James Sprunt Community College
February 4, 2003; 7-9 p.m.; Williamston — Martin Community College (Bldg. 2 Auditorium)
February 6, 2003; 7-9 p.m.; Iredell; Iredell County Center
Further information can be obtained by reviewing the Fact Sheet available at the website and address
listed above.
Cc: Washington-Regional-0- ffice,-Qivision-of-Water Quality
Gates Soil and Water Conservation District
Permit Application File 37 - 15
Non -Discharge Permitting Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
Customer Service Center
An Equal Opportunity Action Employer
A*A
NCl ENR
Internet http://h2o.enr.nc.state.us/ndpu
Telephone [phone] Fax [phone]
Telephone [phone]
50% recycled/10°% post -consumer paper

NCDA onomic Division
4300=Reed Creek -Road .=Ralei
, NCy27607.,6465_ 919s733=z655,, . ; .
=
Re rt No: 27330
Grower: Lilley, Paul
Copies to:
146 NC 37 South
Gatesville, NC 27938-
3
yr :�
.F .
oilTestReport
a
jj
`-
rarm.• 53
�
OCTQCT
1
ZQOi
�
3/30/01 SERVING N.C. CITIZENS FOR OVER 50 YEARS Gates County
);
Agronomist Comments:
�-
A -- 3,12
Field Information
lied=Circe
'Recoinniendations
Sample No. Last Crop
Mo
Yr T/A
Crop or Year
Lime N Pa05 KO
Mg Cu
Zn
B
Mn
See Note
I Cotton
1st Crop: Corn Grain
0 120-16o 0 10-30
0 0
0
0.
3
2nd Crop: Peanuts
01.• 0 0 0-20
0 0
0
.5
0
3
Test Results
Soil Class HM% W/V CEC
BS%
Ac pH P-I
K-1 Ca% Mg% Mn-I Mn-AI (1)Mn-AI (2) Zn-I
Zn-AI
Ca-1
S-r.
SS-1
N(3-N NF�-N Na
MIN 0.81
6.
1.0
0.6 6.3 66
65 73.0 13.0 76 58 51 85
85
13
5
0.1
n:.1.23
Field•Informatio.
rx
^
Sample No. Last Crop
Mo
Yr T/A
Crop or Year
Lime N W 5 K0
Mg Cu
Zn
B
Mn
See Note
2 Cotton
Is( Crop: Corn Grain
0 120-160 0 2040
0 0
0
0
3
2nd Crop: Peanuts
0 0 0 0-20
0 0
0
.5
0
3
Test Results
Soil Class HM% W/V CEC
BS%
Ac pH P-1
K 1 Ca% Mg% Mn-1 Mn-AI fl) Mn-Al (2) Zn-1
Zn-Al
Cu-1
S-1
: SS-1
NO3-N AB-N Na
MIN 0.81 1,23
6.8
1.0
o.6 6.o 130
56 75.0 13.0 80 65 58 114
114
151
'58
0A
Field Information
Applied
Lime
Recommendations
Sample No. Last Crop
Mo
Yr T/A
Crop or Year
Lime N M5 M
Mg Cu
Zn
B
Mn
See Note
3 Corn Grain
1st Crop: Soybeans
0 0 0 0-20
0 0
0
0
3
2nd Crop:
Test Results
Soil Class HM% W/V CEC
BS%
Ac pH P-I
K 1 Ca% • Mg% Mn-1 Mn-Al (1) Mn-AI (2) Zn-I
Zn-AI
Cu-I
S I
SS-1
NO3-N N&N Na
MIN 1.08 1.22
6.6
86.0
0.9 5.8 195
74 67.0 14.0 98 72 135
135
128
45
0.1
Field Information
Applied
Lime
Recommendations F:
Sample No. Last Crop
Ma
Yr TIA
Crop or Year
Lime N P205 h0
Mg Cu
Zn
B
Mn
See Note
4 Cotton
1st Crop: Corn Grain
0 120-16o 0 50-70
0 0
0
0
3
2nd Crop: Peanuts
01 0 0 40-60
0 0
0
.5
0
3
Test Results
Soil Class HM% W/V CEC
BS%
Ac pH P-1
K-1 Ca%•- " Mg% .Mn-I Mn-AI (1) Mn-AI (2) Zn-I
Zn-Al
Cu-1
S I
SS-1
NO3-N NI-N Na
MIN 0.81 123
5.9
88.0
0.7 5.9 73
39 73.0 12.0 76 64 57 101
101
136
51
0.1

-S - N v - L 1
_'.•+ �Ws g 3`= 'S...ry_1."f.G`ir �6-ei�M'Aa J
`=NC&-- onomic Division--,4300�Reed ;Creek -Road �<<Ralei ;;NC_ %0'7r 64d5 e 919 =733 d55� Grower. Lille ;Paul° Re rt No::;27330'
P. 2
..
Fie1d1nfarmation
Sample No. Last Crop
Mo
Yr T/A
Crop or Year
Lime
N P205 KO
Mg Cu
Zn
B
Mn
See Note
5 Soybeans
Ist Crop: Corn Grain
0
120-160 0 10-30
0 0
0
0
3
2nd Crop:
Test Results
Soil Class HM% W/V
CEC
BS%
Ac pH P-1
K-1
Ca% Mg%
Mn-I Mn-AI (1)Mn-AI (2) Zn-1
Zn-AI
Cu-I
S-I
SS-1
NC8-N AVb-N
Na
MIN 1.19 I22
6.1
87.0
0.8 5.9 100
65
67.0 14.0
72 62 140
140
70
42
0.1
Field Information
Applied
Lime
Recommendations
Sample No. Last Crop
Mo
Yr T/A
Crop or Year
Lime
N P105 ko
Mg Cu
Zn
B
Mn
See Note
8 Corn Grain
istCrop: Soybeans
0
0 0 0-20
0 0
0
0
3
2nd Crop:
Test Results
Soil Class HM% W/V
CEC
BS%
Ac pH P-I
K-I
Ca% Mg%
Mn-I Mn-AI (1) Mn-AI (2) Zn-1
Zn-AI
Cu-1
S I
SS -I
NQs-N AH-N
Na
MIN 0.76 1.21
6.1
90.0
0.6 6.2 81
73
70.0 14.0
76 53 68
68
83
37
0.1
Field Information
lied Lime
Sample No. Last Crop
Mo
Yr T/A
Crap or Year
Lime
N M5 ISO
Mg Cu
Zn
B
Mn
See Note
9 Corn Grain
1st Crop: Peanuts
0
0 0-20 0
0 0
0
.5
0
3
2nd Crop:
Test Results
Soil Class HM% W/V
CEC
BS%
Ac pH P-1
K-1
Ca% Mg%
Mn-I Mn-A1(1)Mn-AI (2) .Zn-I
Zn-AI
Cu-1
S-1
SS -I
NQs-N Nlh-N
Na
MIN 0.66 1.21
5.6
8.0
0.6 6.2 43
81
70.0 12.0
65 46 63
63
112
35
0.1
Field Information
lied Lime
Recommendations'
Sample No. Last Crop
Mo
Yr T/A
Crop or Year
Lime
N P205 KO
Mg Cu
Zu
B
Mn
See Note
10 Fes/OG/Pim,M
1st Crop: Fes/OG/Pim,M
0
120-200 0 0
0 0
0
0
12
2nd Crop:
Test Results
Soil Class HM% W/V
CEC
BS%
Ac pH P-1
K I
Ca% Mg%
Mn-1 Mn-AI (1) Mu -AI (2) Zn-I
Zn-AI
Cu-1
S-1
SS-1
NO3-N Nh5-N
Na
M1N 1.74 L14
8.4
89.0
0.9 6.3 90
186
59,0 20.0
64 51 100
100
88
42
0.3
Field Information
lied Lime
Recommendations
Sample No. Last Crop
Mo
Yr T/A
Crop or Year
Lime
N P205 No
Mg Cu
Zn
B
Mn
See Note
12 Corn Grain
Is(Crop: Soybeans
0
0 0 10-30
0 0
t}
0
3
2nd Crop:
Test Results
Soil Class HM% W/V
CEC
BS%
Ac pH P-I
K-1
Ca% Mg%
Mn-1 Mn-AI (1) Mn-AI (2) Zn-1
Zn-AI
Cu-1
S-1
SS-1
NO3 N Nth-N
Na
MIN 1.02 1.20
9.0
91.0
0.8 6.2 136
64
67.0 21.0
73 51 125
125
79
51
0.1

State of North Carolina
Department of Environment
•
and Natural Resources
f
Division of Water Quality
Michael F. Easley, Governor
NCDENR.....,
Sherri Evans -Stanton, Acting Secretary
Kerr T. Stevens, Director
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
January 12, 200I
i JAN 22 2001
PAUL LILLEY;
PAUL LILLEY FARM
RT 1 BOX 47
�y—Dom;-1L
GATESVILLE NC 27938
Subject: Application No. AWS370015
Additional Information Request
Paul Lilley Farm
Animal Waste Operation
Gates County
Dear Paul Lilley:
The Non -Discharge Permitting Unit has completed a preliminary engineering review of the subject application.
Additional information as required before we can continue our review. Please address the following by February 11, 2001:
Your facility was certified for 90 Farrow to finish operation. However, your waste utilization plan (WUP) is for 20
Farrow to Wean, 450 Feeder to Finish and 180 Wean to feeder operation, a lower size than certified. Please verify if
you would like to be permitted for a lower sized farm. If so, consult your technical specialist to make necessary
corrections to match the operation type and size on certification, WUP, and permit application.
2. When utilizing soybeans in a crop rotation, residual nitrogen should be accounted for in the next crop. It
appears that the nitrogen residual from soybeans is not accounted for in Table 1 of your Waste Utilization
Plan (WUP) submitted. Please contact your technical specialist to review your Waste Utilization Plan
(WUP) and revise the WUP to account for residual nitrogen from soybeans, if necessary.
Please note that all WUP revisions must be signed and dated by both the owner and the technical specialist.
Please reference the subject permit application number when providing the requested information. All information
should be signed, scaled, and submitted in duplicate to my attention at the address below. The information requested by this
letter must he submitted on or before February 11, 2001 or the Division will return your application as incomplete in
accordance with 15A N.C.A.C. 2H .0200 and your facility will be considered to be operating without a permit.
Please be advised that operation of the subject animal waste management system without a valid permit is a violation
of North Carolina General Statute 143-215.1 and will subject you to the enforcement authority of the Environmental
Management Commission.
If you have any questions regarding this request, please call me at [phone], extension 363.
Sincerely,
JR Joshi
Non -Disc arge Permitting Unit
cc: Washington Regional Office, Water Quality
Permit File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
Paul Lilley
Paul Lilley Farm
Rt 1 Box 47
Gatesville NC 27938
Dear Paul Lilley:
0190WA
IT
A&4;1 0 2
As
NCDENR
NORTH CAROONA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
j
i t S I�7 i C •� I I
December 30, 1999
JAN 1 0 2000 ! '
WASHINGTON REGIONAL OFFICE
DWQ
Subject: Fertilizer Application Recordkeeping
Animal Waste Management System
Facility Number 37-15
Gates County
This letter is being sent to clarify the recordkeeping requirement for Plant Available Nitrogen (PAN)
application on fields that are part of your Certified Animal Waste Management Plan.
In order to show that the agronomic loading rates for the crops being grown are not being exceeded, you
must keep records of all sources of nitrogen that are being added to these sites. This would include nitrogen
from all types of animal waste as well as municipal and industrial sludges/residuals, and commercial fertilizers.
Beginning January 1, 2000, all nitrogen sources applied to land receiving animal waste are required to
be kept on the appropriate recordkeeping forms (i.e. ER -RI, HZR2, DRY], DRY2, DRY3, SLUR1, SLUR2,
SLD1, and SLD2) and maintained in the facility records for review. The Division of Water Quality (DWQ)
compliance inspectors and Division of Soil and Water operation reviewers will review all recordkeeping during
routine inspections. Facilities not documenting all sources of nitrogen application will be subject to an
appropriate enforcement action.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Ms. Sonya Avant of the
DWQ staff at [phone] ext. 571.
ONX
cc: Washington Regional Office
Gates County Soil and Water Conservation District
Facility File
Sincerely,
Kerr T. Stevens, Director
Division of Water Quality
1617 Mail Service Center, Raleigh, North Carolina 27699.1617 Telephone [phone] Fax [phone]
An Equal Opportunity Af#irmative Action Employer 50% recycled/10% post -consumer paper