820731_CORRESPONDENCE_20171231

Z V
NORTH CAROLINA ..�
Department of Environmental Quai

ROY COOPER
WCHAEL S. REGAN
secrWary
UNDA CULPEPPER
Inter►m Direaw
Benjamin L. Grady
Pine Ridge Farm #1
P.O. Box 428
Faison, NC 28341
Dear Benjamin L. Grady:
RECEIVED
®EQIDWR
AUG 1 S Cl118
NORTH CAROLINA
&W&VftMftUdQuolley
-14
August 8, 2018
Subject: Certificate of Coverage No. AWS820731
Pine Ridge Farm #1
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
In accordance with your July 27, 2018 request to change operation type without exceeding the permitted
steady state live weight, we are hereby forwarding to you this Certificate of Coverage (COC) issued to
Benjamin L. Grady, authorizing the operation of the subject animal waste management system in
accordance with General Permit AWG100000_
This approval shall consist of the continued operation of the existing animal waste management system
including, but not limited to, the management and land application of animal waste as specified in the
facility's Certified Animal Waste Management Plan (CAWMP) for Pine Ridge Farm #1, located in
Sampson County, with a swine animal capacity of no greater than the following annual averages:
Wean to Finish: 6354 Feeder to Finish: Boar/Stud:
Wean to Feeder: Farrow to Wean: Gilts:
Farrow to Finish: Farrow to Feeder: Other:
If this is a Farrow to Wean or Farrow to Feeder operation, there may be one boar for each 15 sows. Where
boars are unnecessary, they may be replaced by an equivalent number of sows. Any of the sows may be
replaced by gilts at a rate of 4 gilts for every 3 sows.
This COC shall be effective from the date of issuance until September 30, 2019, and shall hereby void
Certificate of Coverage Number AW S820731 dated July 21, 2017. Pursuant to this COC, you are authorized
and required to operate the system in conformity with the conditions and limitations as specified in the
General Permit, the facility's CAWMP, and this COC. An adequate system for collecting and maintaining
the required monitoring data and operational information must be established for this facility. Any increase
in waste production greater than the certified design capacity or increase in number of animals authorized
by this COC (as provided above) will require a modification to the CAWMP and this COC and must be
completed prior to actual increase in either wastewater flow or number of animals.
North Carolina Deparhnent of Env[run Hemel Qualtry I DMsion of Water Resources
512 North Salisbury Street 1 1611 Mail Service Center R Raleigh, North Carolina 27699-1611
919.707.9000

Please read this COC and the enclosed State General Permit carefully. Please pay careful attention to the
record kegping_and monitoring conditions in this permit. Record keeping forms are unchanged with this
General Permit. Please continue to use the same record keeain¢ forms.
If your Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor floes issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Per NRCS standards a 100-foot separation shall be maintained between water supply wells and any lagoon,
storage pond, or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Program for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition 1I.22 of the General Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Tropical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You may
find detailed watch/warning information for your county by calling the Raleigh, NC National Weather
Service office at [phone], or by visiting their website at: http://www.weather.gov/rah/
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office staff
may be reached at 919433-3300. If you need additional information concerning this COC or the General
Permit, please contact the Animal Feeding Operations Program staff at [phone].
Sincerely,
, J. L
��
or Linda Culpepper
Interim Director, Division of Water Resources
Enclosure (General Permit AWG100000)
cc: (Certificate of Coverage only for all ccs)
Fayetteville Regional Office, Water Quality Regional Operations Section
Sampson County Health Department
Sampson County Soil and Water Conservation District
WQROS Central Files (Permit No. AWS820731)
Maxwell Foods, Inc. — PO Box 10009, Goldsboro, NC 27532
��-D-E Q5
North Carolina Department of Envlravnrntal Qua[" I Nvision of water Resources
512 Norm SaKsMay Street 1 160 Mail Service Centrr I Raleigh, North Carolina 27699-1611
9193M 9000

Environmental
Quality
B. L. Grady
Farm 2148
P. O. Box 428
Faison, NC 28341
Dear B. L. Grady:
RECEIVED
DEQIDWR
JUL 2 4 2017
WQROS
FAYETTEVILLE REGIONAL OFFICE
July 21, 2017
ROY COOPER
Governor
MICHAEL S. REGAN
Secretary
S. JAY ZiMMERMAN
Director
Subject: Certificate of Coverage No. AWS820731
Farm 2148
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
In accordance with your July 17, 2017 Notification of Change of Ownership, we are hereby forwarding to
you this Certificate of Coverage (COC) issued to B. L. Grady, authorizing the operation of the subject
animal waste management system in accordance with General Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management Plan
(CAWMP) for Farm 2148, Iocated in Sampson County, with a swine animal capacity of no greater.than the
following annual averages:
Wean to Finish: Feeder to Finish: Boar/Stud:
Wean to Feeder: Farrow to Wean. Gilts:
Farrow to Finish: Farrow to Feeder: 1,400 Other:
If this is a Farrow to Wean or Farrow to Feeder operation, there may be one boar for each IS sows. Where
boars are unnecessary, they may be replaced by an equivalent number of sows. Any of the sows may be
replaced by gilts at a rate of 4 gilts for every 3 sows.
This COC shall be effective from the date of issuance until September 30, 2019, and shall hereby void
Certificate of Coverage Number AWS820731 dated October 1, 2014. Pursuant to this COC, you are
authorized and required to operate the system in conformity with the conditions and limitations as specified
in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting and
maintaining the required monitoring data and operational information must be established for this facility.
Any increase in waste production greater than the certified design capacity or increase in number of animals
authorized by this COC (as provided above) will require a modification to the CAWNIP and this COC and
must be completed prior to actual increase in either wastewater flow or number of animals.
Please read this COC and the enclosed State General Permit carefully. Please pay careful attention to the
record keeping and monitoring conditions in this permit. Record ke m forms are unchanged with this
General Permit Please continue to use the same record keeping forms.
`Nothing Compares
State of North Carolina I Environmental Quality I Division of Water Resources
Water Quality Regloaul Operatious Section
1636 Mail Service Center I Raleigh, North Carolina 27699-1636
919-707-9129

If your Waste Utilization flan (WUP) has been developed based on site -specific information, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Per NRCS standards a 100-foot separation shall be maintained between water supply wells and any lagoon,
storage pond, or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-2I5.6C including civil penalties, criminal penalties, and injunctive relief.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Program for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition 11.22 of the General Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Tropical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You may
find detailed watch/warning information for your county by calling the Raleigh, NC National Weather
Service office at [phone], or by visiting their website at: hqp://www.weather. ovg /rah/
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office staff
may be reached at 910-433-3300. If you need additional information concerning this COC or the General
Permit, please contact the Animal Feeding Operations Program staff at [phone].
Sincerely,
Lar, S. Jay Zimmerman, P.G.
Director, Division of Water Resources
Enclosure (General Permit AWG 100000)
cc: (Certificate of Coverage only for all ccs)
Fayetteville Regional Office, Water Quality Regional Operations Section
Sampson County Health Department
Sampson County Soil and Water Conservation District
WQROS Central Files (Permit No. AWS820731)
Smithfield Hog Production

Writer Resources
ENVIRONMENTAL QUAMY
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Murphy -Brown LLC
Farm 2148
PO Boa 856
Warsaw, NC28398-0856
Dear Permitlee,
PAT MCCRORY
Gorenwr
DONALD R. VAN DER VAART
Secretary
S. JAY ZIMMERMAN
Director
July 8, 2016 RECEIVED
DEQ/DWR
JUL 12 2016
FAYETTEVILLEQROONAL OFFICE
Subject: Notice of Deficiency
Farm 2148
Permit Number AWS820731
Sampson County
As of this date, our records indicate that the above -referenced permit issued to your facility has
overdue fees. It is both a condition of your permit and required by Rule 15A NCAC 2T .0105(e) (2) to }gay
the annual administering and compliance fee within thirty (30) days of being billed by this Division.
The following invoices are outstanding:
Invoice Number
Fee for Years
Due Date
Outstanding Fee (S)
2015PR003780
2012, 2013, 2014
5/2412015
540
Failure to pay the fee accordingly may result in the Division initiating enforcement actions, to
include the assessment of civil penalties. Failure to comply with conditions in a permit may result in a
recommendation of enforcement action, to the Director of the Division of Water Resources who may issue
a civil penalty assessment of not more that twenty-five thousand ($25,000) dollars against any "person'
who violates or fails to act in accordance with the terms, conditions, or requirements of a permit under
authority of G.S. 143-2t5.6A. Therefore, it is imperative that you submit the appropriate fee as requested
within thirty (30) days of this Notice of Deficiency.
Please remit the payment, made payable to the North Carolina Department of Environmental
Quality (NCDEQ), in the above amount. Please include Permit Number on your check and mail this
payment to:
Division of Water Resources — Budget Office
Attn: Teresa Revis
1617 Mail Service Center
Raleigh, NC 27699-1617
Phone: [phone]
-contd-
State of North Carolina I Envirorunerual Quality I Water Resourcesiwater Quality Regional operations
1636 Mail service Center � Raleigh, North Carolina 27699-1636
919 907 6464

If you have any questions concerning this Notice, please contact Animal Feeding Operations
Program staff at [phone].
Sincerely,
Debra J. Watts, Supervisor
Animal Feeding Operation, and
Ground Water Protection Branch
cc: Fayetteville Regional Office, Water Quality Regional Operations Section
WQROS Central File (Permit No AWS820731)
0

t 4 ,%
Murphy -Brown L.c
May 7, 2014
NCDENR DWR
Fayetteville Regional Office
225 Green Street
Suite 714 / Systel Bldg.
Fayetteville, NC 28301-5043
Subject: Burial Site Map for
Farm 2148; Fac. No.: 82-731
Sampson County
PO Drawer 856
2822 Hwy. 24 West
Warsaw, NC 28398
Tel: [phone]
Fax: [phone]
RECEIVED
MAY - 8 2014
DENR-FAYErTBILLE REGIONAL OFHCE
Enclosed please find a copy of the map of the burial site for the above -mentioned facility where during
September —October 2013, 550 nursery, 50 finishing and 6 sow animals, and 5 cows were buried in Dead
Hole A in accordance with the facility's CAWMP and the NCDA&CS Veterinary Division's Statutes and
regulations. This was due to above normal mortality at this facility. Please place in the appropriate files.
If you have any questions regarding this matter, please do not hesitate to call me at [phone] east.
5363.
Cc: Murphy -Brown, LLC Files
Sincerely,
/Z. - _-
Kevin Weston, CID
Environmental Compliance

. 4 9A .
NCDENR
North Carolina Department of Environment and Natural Resources
Beverly Eaves Perdue
Governor
Murphy -Brown, LLC
Farm 2148
PO Box 856
Warsaw, NC 28398
Dear Murphy -Brown, LLC:
Division of Water Quality
Coleen H. Sullins
Director
May 5, 2011
Dee Freeman
Secretary
Subject: Certificate of Coverage No. AWS820731
Farm 2148
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
In accordance with your May 2, 2011 request to separate previously combined and permitted facilities
(Facility Nos. 82-14 and 82-399, now 82-731), we are hereby forwarding to you this Certificate of
Coverage (COC) issued to Murphy -Brown, LLC, authorizing the operation of the subject animal waste
management system in accordance with General Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for the Farm 2148, located in Sampson County, with a swine animal capacity of no
greater than the following annual averages:
Wean to Finish: Feeder to Finish: Boar/Stud:
Wean to Feeder: Farrow to Wean: Gilts:
Farrow to Finish: Farrow to Feeder: 1400 Other:
If this is a Farrow to Wean or Farrow to Feeder operation, there may be one boar for each 15 sows. Where
boars are unnecessary, they may be replaced by an equivalent number of sows. Any of the sows may be
replaced by gilts at a rate of 4 gilts for every 3 sows.
The COC shall be effective from the date of issuance until September 30, 2014, and shall hereby void
Certificate of Coverage Number AWS820014 dated October 1, 2009. Pursuant to this COC, you are
authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit. the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Please pay careful attention to the
record keeping and monitoring -conditions in this permit. Record keeping forms are unchanged with this
General Permit. Please continue to use the same record keeping forms.
1536 Mail Service Center, Ralegh, North Garaiina 27699-1636
Location: 2728 Capita! Blvd., Raleigh, Norm Garoiina 27604 One
phone:[phone] LFAX: 919-715-05881Customer Service. 1-877-623-6748 Noi-thCarolina
Internet: wvwl.ncwaterquality.org Jt�/ %/r
An Eaui2 OPponan Y'i Af&rr auas c ian Ernpdoyer Nat 1'*all y

If vour Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
The issuance of this COC does not excuse the Permirtee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Per 15A NCAC 2T .0105(h) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100-foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, then an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be stibmitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Unit for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition 1I.22 of the General Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Tropical Storm Warning;
or a Flood Watch associated with a tropical system for the county in which the facility is located. You
may find detailed watch/waming information for your county by calling the Raleigh, NC National
Weather Service office at [phone], or by visiting their website at: www.erh.noaa.gov/er/rah/
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Aquifer Protection Staff may be reached at [phone]. If you need additional information
concerning this COC or the General Permit, please contact the Animal Feeding Operations Unit staff at
(919) 733-322) .
Sincerely,
for Coleen H. Sullins
Enclosure (General Permit AWG 100000)
cc: (Certificate of Coverage only for all ccs)
Fayetteville Regional Office, Aquifer Protection Section
Sampson County Health Department RECEIVED
Sampson County Soil and Water Conservation District
APS Central Files (Permit No. AWS82073 l) MAY 10 2011
AFO Notebooks
Murphy -Brown, LLC
DENR-EAYETTEVIIII: REGIONAL OFFICE

Murphy-BrOwn LLC
October 19, 2011
NCDENR, DWQ
Fayetteville Regional Office
Aquifer Protection Section
225 Greets Street
Suite 714 f Systel Bldg.
Fayetteville, NC 28301-5043
Subject: Revised Nutrient Utilization Plan and
Irrigation System Design Parameters for
2148
Facility No- S2_Z3!1
Sampson County
PO Drawer 856
2822 Hwy. 24 West
Warsaw, NC 28398
Tel: [phone]
Fax: [phone]
GCT z 0 2011
DENR -FAY TEV LLE REGC-4AI.ME
Enclosed please find the revised Nutrient Utilization Plan and Irrigation System Design Parameters for the
above -mentioned facility. The revision was made to update the wetted acres due to a new GPS map of the
facility. All other parameters remained the same. Please place in the appropriate file.
If you have any questions or need additional information regarding this matter, please do not hesitate to call
me at [phone] ext. 5363.
Sincerely,
Kevin Weston, CID
Environmental Compliance
Cc: Sampson SWCD
Murphy -Brown. LLC Files

Sheetl
IRRIGATION SYSTEM DESIGN PARAMETERS
Landowner/Operator Name. Murphy -Brown, LLC - Farm 2148; Fac. No.: 82-731 County: Sampson
Address: P.O. Box 856
Warsaw, NC 28398 Date: 10/18/2011
Telephone: [phone]
Table 1 - Field Specifications
Approximate
Maximum
Maximum
Maximum
Application
Useable Size
Application
per Irrigation
Field of Field
Rate
Cycle
Number (acres) Soil Type Slope % Crop(s)
(Inthr)
(Inches)
Comments
I�
• N
i�i��
BermudaI.
�Bermuda/
�-
Small Grain
�
Iff • f
• .Small Graini
•

Sheet2
TABLE 2 - Travelling irrigation Gun Settings
Make, Model and Type of Equipment: Traveler w/3.7"x1100' hose & Nelson 150
Field No. Travel Application TRAVEL LANE Wetted Nozzle Operating Operating
and Speed Rate Effective Effective Diameter Diameter Pressure Pressure Arc
Hvdrant No. (ft/min) (in/hr.) Width(f_t)____ _ LenVNft) (feet) (Inches) at Gun sl at reel(psl) Pattern Comments - Acres per pull

Sheet3
TABLE 3 - Solid Set Irrigation Guru Settings
Make, Model and Type of Equipment Nelson 100
Operating Parameters
Field No Wetted Hydrant Spacing(H) Application Nozzle Operating Operating
and Number of Diameter Along Between Rate Diameter Pressure Time
• _ t1i1�Ti=Imi��1�71�9ii�ll�LII� ' - •

Sheet5
IRRIGATION SYSTEM DESIGNER
obi
Name: Micah Kevin Weston, CID y�
Company: Murphy -Brown, LLC
Address; 2822 Hwy 24 West, P.O. Box 856 Warsaw, NC 28396
Phone: [phone] _Q02919
Required Documentation
The following details of design and materials must accompany all irrigation designs:
1. A scale drawing of the proposed Irrigation system which includes hydrant locations, pipelines, thrust block locations and buffer areas where applicable.
2. Assumptions and computations for determining total dynamic head and horsepower requirements.
3. Computations used to determine all mainline and lateral pipe sizes.
4. Sources and/or calculations used for determining application rates.
5. Computations used to determine the size of thrust blocks and illustrations of all thrust block configurations required In the system
6. Manufacturer's specifications for the irrigation pump, traveler and sprinkler(s)
7. Manufacturer'a specifications for the Errigation pipe and/or USDA-NFtCS standard for IRRi©ATION WATER CONVEYANCE.
8. The information required by this form are the minimum requirements, It Is the responsibility of the designer to consider all relevant factors at a particular site and
address them as appropriate.
9. Irrigation pipes should not be installed in lagoon or storage pond embankments without the approval of the designer.
NOTE: A buffer strip of 25' or wider must be maintained between the Ilm Its of the Irrigation system and all
perennial streams and surface waters per NC Statutes.

Sheet6
Narrative of Irrigation System Operation
This design is a "wetted acreage" determination for an existing facility. The acres were calculated based on
the equipment specified and the charts created by NCSU for calculating Area Allowances for Stationary
Sprinkler Systems and Area Allowances for Hard Hose Traveler Systems.
Refer to owner's manual and irrigation dealer for information on maintenance, winterization, and operation of
system.

Sheet7
CALCULATIONS
Sprinkler Specifications
Sprinkler Type: Nelson 150
Nozzle Size:
1.18 inches
Sprinkler Pressure:
60 psi
Flowrate(GPM):
229 gpm
Wetted Diameter:
283.5 feet ` Reflects a 10% reduction from chart
Lane Spacings
Desired Spacing (%):
70 %
Design Spacing(feet):
198.45 'PVC irrigation pipe normally comes in 20' pieces,
so round to the nearest m ultiple of 20.
Actual Spacing (feet):
220 feet
Actual Spacing (%):
78 %
Application Rate
Application Rate = (96.3xFlowrate)/(3.1415x(.gxradius)squared)
Design App. Rate =
0.43 in/hr
300 degree arc =
0.52 in/hr 330 degree arc = 0.47 in/hr
220 degree arc =
0.71 in/hr
180 degree arc =
0.86 in/hr
Traveller Speed
Travel speed = 1.605 x Flowrate / Desired application amount x Lane Spacing
Desired app. (in.) = 0.5 inches 360 degree arc = 3.34 ft/min
300 degree arc = 4.01 ft/min 330 degree arc = 3.64 ft/min
220 degree arc = 5.35 ft/min
180 degree arc = 6.68 tYrnin
Mainline Velocit►►
Velocity = .408 x Flowrate / pipe diameter squared feet/sec."
"For buried pipelines, velocity should be below 5 feet per second
Pipe size: inches
Velocity-- #DIV/O! ft/sec.
Page 1

Sheet? (2)
CALCULATIONS
Sprinkler Specifications
Sprinkler Type:
Nozzle Size:
inches
Sprinkler Pressure:
psi
Flowrate(GPM):
65 gpm
Wetted Diameter
215 feet * Reflects field measurement
Sprinkler Spacinas
Desired Spacing (%):
60 %
Design Spacing(feet):
129 *PVC irrigation pipe normally comes in 20' pieces,
so round to the nearest multiple of 20.
Actual Spacing (feet):
80 feet
Actual Spacing (%):
37 %
Application Rate
Application Rate = (96.3xFlowrate)/sprinkler spacing squared
Design App. Rate =
0.98 in/hr
Run Time on Set
Run fte per set = Desired application / Design application rate = hours
Desired app. (in.) =
0.5 inches
Run time per set =
0.51 hours
Mainline, VelvcitY
Velocity= .408 x Flowrate / pipe diameter squared feet/sec_**
"For buried pipelines, velocity should be below 5 feet per second
Pipe size:
inches
# Sprinklers Oper.:
Velocity-_
#DIV/0! ft/sec.
Maximum Lateral Line Entrance Velocity
Pipe size:
2 inches 4 inches
# Sprinklers Oper.:
Velocity =
0.00 ft/sec. 0.00 ft/sec_
Page 1

5heel8
.:wrllmmroymr
--�-
-®�
r rrr
r rrr
r r:
rrrNEW
����
r •rr��
r rrr
r r:
rrr
rrr
-���
r rrr��
r rrr
r r:
rrr
rrr
-���
r rrr��
r rrr
r r:
rrr
rrr
-®��
r rrr��
r rrr
r r:
rrr
rrr
-���
r rrr��
r rrr
r r:
rrr
rrr
Page 1

Sheet8 (2)
Farm 2148; Fac. No.: 82.731
Acreage Calculations - 10/18/2011
Width
Length
Acres
es
*4,789
Start End
StopEnd
Total
Pull #
ft.
flu
(midsection)on
ac.
ac.
Pull Acres
1
255
818
4.789
0.584
0.491
5.86
2
255
958
5.608
5.808
0.584
0.491
6.68
3
255
958
5.608
5.608
0.584
0.491
6.68
4
128
333
0.979
3.125
0.438
0.245
3.81
219
427
2.147
0.000
0.000
0.000
0.00
5
239
538
2.952
2.952
0.438
0.245
3.64
6
203
478
2.228
2.228
0.438
0.245
2.91
7
252
674
3.899
3.899
0.882
0.555
5.14
8
220
684
3.455
3.455
0.636
0.519
4.61
9
i 70
262
1.022
1.636
0.682
0.555
2.87
252
106
0.613
0.000
0.000
0.000
0.00
0
0
0.000
0.000
0.000
0.000
0.00
0
0
0.000
0.000
0.000
0.000
0.00
0
0
0.000
0.000
0.000
0.000
0.00
0
0
0.000
0.000
0.000
O.000
0.00
0
0
0.000
0A00
0.000
0.000
0.00
0
0
0.000
0.000
0.000
0.000
0.00
0
0
0.000
0.000
0.000
0.000
0.00
0
0
0.000
0.000
0.000
0.000
0.00
0
0
0.000
0.000
0.000
0.000
0.00
0
0
0.000
0.000
0.000
0.000
0.00
Total Acres
1 42.20
Page 1

Farm 2148
Fac. No.: 82-731
Total Field 3 = 3.83 Ac.
6
Wetted = 2.91 Ac.
Sub 3 = 0.92 Ac.
We w/100'
Total Field 4
= 16.39 Ac.
athrt.
Wetted
= 13.13
Ac.
Sub 4 =
3.26
Ac.
5
2 1
7
4 3
8
Total Field 2 = 7.20 Ac.
Wetted = 3.64 Ac.
Sub 2 = 3.56 Ac.
9
10
Pull Acres
1 5.86
2 6.68
3 6.68
�EVmow
4 3.81
5 3.64
6 2.91
8 4.61
Total Field 1 = 31.47
Ac.
_
9 2.87
Wetted = 23.03 Ac.
Sub
002919
10 0.51
1 = 8.44 Ac.
Aps, �y a
Total 42.71
d'pl�IN���

Murphy -Brown, LLC 10/18/2011 2822 Hwy 24 West
P. a. Box 856
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Grower(s):
Farm Name:
Murphy -Brown, LLC
2148; Fac. No.: 82-731
County- Sampson
Farm Capacity,
Farrow to Wean
Farrow to Feeder 1400
Farrow to Finish
Wean to Feeder
Feeder to Finish
Storage Structure:
Storage Period:
Application Method:
Anaerobic Lagoon
> 180 days
Irrigation
6 ECE-� IE
OCT 2 0 2011
DENR 4AYL TEVR.L REU%'Al- OFFICE
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 11

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be fiexlble so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H _0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, fe, tons, etc.):
Type Waste Produced per Animal Total
Farrow to Wean
3212 gal/yr
gaVyr
1400
Farrow to Feeder
4015 gal/yr
5,621,000 gaVyr
Farrow to Finish
10585 gal/yr
gaVyr
Wean to Feeder
223 gaVyr
gal/yr
Feeder to Finish
9W gallyr
gal/yr
Total 5,621,000 gal/yr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (Ibs):
Type Nitrogein Produced per Animal Total
Farrow to Wean
5.4 Ibs/yr
Ibslyr
1400
Farrow to Feeder
6.5 Ibstyr
9,100 Ibslyr
Farrow to Finish
26 Ibslyr
Ibs/yr
Wean to Feeder
0.413 Ibalyr
Ibslyr
Feeder to Finish
2.3 f V
lbsfyr
Total 9,100 IbsV
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 58.89
Total N Required 1st Year: 18893.78
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops: 18,893.78
Total Nitrogen Produced by Farm: 9,100.00
Nitrogen Balance for Crops: (9,793.78)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2 of 11

.: R
,.
•�.
3(s) a1 11

'Reception Area SpecifIcations
Acreage TV . .... Code ply Yield We N/UnIt Residual /Ac Utilized
Traet Field Irrigated Soil 1 at Crop TlFmto latCrap ..
3(b) of 11

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result 9 small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or earty October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized / unit yield
A
Barley
1.6 lbs N 1 bushel
S
Hybrid Bermudagrass - Grazed
50 lbs N / ton
C
Hybrid Bermudagrass - Hay
50 lbs N / ton
D
Com - Grain
1.25 lbs N / bushel
E
Com - Silage
12 lbs N 1 ton
F
Cotton
0.12 lbs N / lbs lint
G
Fescue - Grazed
50 lbs N 1 ton
H
Fescue - Hay
50 lbs N / ton
[
Oats
1.3 lbs N 1 bushel
J
Rye
. 2.4 lbs N 1 bushel
K
Small Grain - Grazed
50 lbs N 1 acre
L
Small Grain - Hay
50 lbs N / acre
M
Grain Sorghum
2.5 lbs N / cwt
N
Wheat
2.4 lbs N 1 bushel
O
Soybean
4.0 lbs N / bushel
P
Pine Trees
40 lbs N 1 acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4 of 11

SLUDGE APPUCA71ON:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications P /animal Farm To
Farrow to Wean o.84
1400 Farrow to Feeder 1 1400
Farrow to Finish 4.1
Wean to Feeder 0.072
Feeder to Finish 0.36
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 1400 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 7000 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 23 acreas of land. If you apply the sludge
to com at a rate of 125 pounds per acre, you will need 56 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids_ The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
"This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every B months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one toot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 11

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
soil
Application Rate
Application Amount
Tract
Hydrant
Type
Crop
Inthr
• Inches
T3408
1
Norfolk
B/C
0.5
1
T3408
Z
Norfolk
B/C
0.5
1
T3408
3
Norfolk
B/C
0.5
1
T3408
4
Norfolk
B/C
0.5
T3408
5
Rains
B/C
0.4
1
T3408
6
Wagram
B/C
0.6
1
T3408
7
Norfolk
B/C
0.5
1
T34GB
8
Norfolk
B/C
0.5
1
T3408
9
Norfolk
B/C
0.5
1
T3408
10
Norfolk
B/C
0.5
1
T3408
Subi
Norfolk
B/C
0.5
1
T3408
Sub2
Rains
B/C
0.4
1
T3408
Sub3
Wagram
BIC
0.6
1
T3408
Sub4
Norfolk
B/C
0.5
1
6 of 11

Additional Comments:
This plan revised to reflect wetted acres.
All other parameters remained the same.
The plan shows bermuda in a hay/graze combination, which means half of
the berm uda will be harvested as hay and half by grazing.
ff the bermuda is to be harvested as hay only, the PAN rate should be:
Norfolk soils - 325 Lbs N/ac_
Rains soils - 225 Ibs N/ac.
Wagram soils - 275 Ibs N/ac_
If the berm uda will be harvested by grazing only, the PAN rate should be. -
Norfolk soils - 243.75 Ibs N/ac.
Rains soils - 168.75 lbs N/ac.
Wagram soils - 206.25 Ibs N/ac.
7 of 11

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: 2148; Fac. No.: 82-731
Owner: Murphy -Brown, LLC
Manager:
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Murphy -Brown, LLC
Signature: /{ /_ _ '/ !�lA` _
Date
Name of Manager (it different from owner):
Signature:
Date
Name of Technical Specialist: M. Kevin Weston
Affiliation: Murphy -Brown, LLC.
Address: 2822 H 24 West, PO Drawer 856
Warsaw, NC 28398
Telephone: [phone] _
Signature:
8 of 11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recieving crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic
crop yields based upon soil type, available moisture, historical data, climatic conditions,
and level of management, unless there are regulations that restrict the rate of applications
for other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field
(See USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips)-
5 Odors can be reduced by injecting the waste or disking after waste application_ Waste
should not be applied when there is danger of drift from the land application field-
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and
flies.
S Animal waste shall not be applied to saturated soils, during rainfall events, or when the
9 of 11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property
boundary and canal. Animal waste, other than swine waste from facilities sited on or after
October 1, 1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 1 OD feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 • Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
10 of 11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
11 of 11

Farm 2148
Fcm Na: 02-731
Total Field 3 = 3.53 Ac.
6
Wetted = 2.91 Ac.
Sub 3 = 0.92 Ac.
Wdo w/1w Total Field 4 = 16.39 Ac.
Oftets
Wetted = 13.13 Ac.
Sub 4 = 3.26 Ac.
5
2 1 7
4 3
8
Total Field 2 = 7.20 Ac.
Wetted = 3.64 Ac.
Sub 2=3.56Ac.
9
10
Pull Acres
1 5.86
2 6.68
3 6.68v1N
4 3.81
5 3.64
6 2.91
8 4.61
Total Field 1 = 31.47 Ac. * i
9 2.87
Wetted = 23.03 Ac. 002414
Sub
10 0.51
1 = 8.44 Ac. $IG%VQ
Total 42.71
RINK1�

n- 731
Murphy -Brown, LLC d,r a 413/2009 )t �04 Of P.C. Box 856
I Warsaw, NC 2&398
Golf#-FAl'l~TfEIlil.i.Er�Fu"dfJt1!�t�� -
NUTRIENT UTILIZATION PLAN
Grower(s):
Farm Name:
Murphy -Brown, LLC
2148/C & M II
County: Sam son
Farm Capacit
Farrow to Wean
Farrow to Feeder 1400
Farrow to Finish
Wean to Feeder
Feeder to Finish 8000
Storage Structure:
Storage Period:
Application Method:
Anaerobic Lagoon
>180 days
Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8 RECEIVED I DENR 1 MNQ
AQUiFr-R'PPC,TR-M0N SFCT!ON
APR 0 7' ?00.9

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility_ In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft3, tons, etc.):
Capacity Type Waste Produced per Animal Total
Farrow to Wean
3212 gallyr
gal/yr
1400
Farrow to Feeder
4015 gal/yr
5.621.000 gal/yr
Farrow to Finish
10585 gallyr
gal/yr
Wean to Feeder
223 ga€!yr
gallyr
8000
Feeder to Finish
986 gal/yr
7,888,000 gallyr
Total 13,509,000 gallyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs):
Capacity Type Nitrogen Produced per Animal Total
Farrow to Wean
5.4 Ibs/yr
Ibs/yr
1400
Farrow to Feeder
6.5 Ibslyr
9,100 Ibslyr
Farrow to Finish
26 Ibslyr
Ibslyr
Wean to Feeder
0.48 Ibslyr
Ibslyr
8000
Feeder to Finish
2.3 Ibslyr
18,400 lbs/yr
Total 27,500 Ibslyr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season,
Total Irrigated Acreage: 124.068
Total N Required 1st Year: 38499.559
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops: 38,499.56
Total Nitrogen Produced by Farm: 27,500.00
Nitrogen Balance for Crops: (10,999.56)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
911 j

Reception Area Specifications
Tract Field Irrigated Soil 1st Crop Time to 1st Crop 1st Crop Lbs NIAc Lbs N Total lbs N
Areea e Type Code Apply Yield Ibs NIUnit Residual /Ac Utilized
2nd Crop Time to 2nd Crop 2nd Crop Lbs N1Ac Lbs N Total ibs NI
Code Apply Yield Ibs NIUnit Residual /Ac Utilized
Total
Lbs N/Ac
Total Ibs Nr
Utilized
3408
1A
0.81
Wa ram
B
Mar -Set
5.5
43.25
238
192.6788
K
Se t-A r
1
50
50
40.5
287.875
233.1788
1B
5.33
Wa ram
B
Mar -Set
5.5
43.25
238
1267.874
K
Sept -Apr
1
50
50
266.5
287.875
1534.374
1C
0.75
Wa ram
B
Mar -Set
5.5
43.25
238
178.4063
K
Sept -Apr
1
50
50
37.5
281.875
215.9063
10
4.65
Wa rem
B
Mar -Set
5.5
43.25
238
1106.119
K
Se t-A r
1
So
50
232.5
287.875
1338,619
1E
0.75
Wa ram
B
Mar -Set
5.5
43.25
238
178.4063
K
Sept -Apr
1
50
50
37.5
287,875
215.9063
1F
4.4
Wa ram
B
Mar -Set
5.5
43.25
238
1046.65
K
Se t-A r
1
5o
50
220
287.875
1266.65
1G
0.81
Waciram
8
Mar -Set
5.5
43.25
238
192.6788
K
Sept -Aix
1
50
50
40.5
287.875
233.1788
1H
0.81
Wa ram
8
Mar -Set
5.5
43.25
238
192,6788
K
Se t•A r
1
50
50
40.5
287.875
233.1788
4A
4.37
Norfolk
B
Mar -Set
6.5
43.25
281
1228.516
K
$e t-A r
1
50
50
218.5
331.125
1447.016
4B
6.3
Norfolk
B
Mar -Set
6.5
43.25
281
1771.088
K
Sept -Apr
1
5o
50
315
331.125
2086.088
4C
4,49
Norfolk
B
Mar -Sat
6.5
43.25
281
1262.251
K
Sept -Apr
1
50
50
224.5
331.125
1486.751
40
3.53
Norfolk
B
Mar -Set
6.5
43.25
281
992.3713
K
Sept -Apr
1
50
50
176.5
331,125
1168,871
4E
1.73
Norfolk
8
Mar -Sat
6.5
43.25
281
486.3463
K
Se t-A r
1
5o
50
86.5
331.125
572.8463
4F 1
1.89
Norfolk
B
Mar -Set
6.5
43.25
281
531.3263
K
Se t-A r
1
50
1 50
94.5
331,125
625.8263
4G
6.2
Norfolk
B
Mar -Set
6.5
43.25
281
1742.975
K
Sept -Apr
1
50
50
310
331.125
2052.975
7A
6.3
Norfolk
B
Mar -Set
6.5
43.25
281
1771.088
K
Sept -Apr
1
50
50
315
331.125
2086.088
76
5.15
Norfolk
B
Mar -Set
6.5
43.25
281
1447,794
K
Sept -Apr
1
50
50
257.5
331.125
1705,294
7C
5.15
Norfolk
B
Mar -Set
6.5
43.26
281
1447.794
K
Sept -Apr
1
50
50
257.5
331.125
1705.294
70
6.3
Wa rem
B
Mar -Set
5.5
43.25
238
14913.613
K
Sept -Apr
1
50
50
315
287.875
1813.613
7E
4.74
Wa ram
B
Mar -Set
5.5
43.25
1
238
1127.528
1 K
Sept -Apr
1
50
50
237
287,875
1364,528
7G
3.37
Wa rem
B
Mar -Sot
5.5
43.25
238
801.6388
K
Sept -Apr
1
50
50
168.5
287.875
970.1388
8A
5.58
Norfolk
8
Mar -Set
6.5
43.25
281
1568.678
K
Sept -Apr
t
50
50
279
331.125
1847.678
86
4.96
Norfolk
8
Mar -Set
6.5
43.25
281
1394.38
K
Sept -Apr
1
50
50
248
331.125
1642.38
8C
4,13
Norfolk
8
Mar -Set
6.5
43.25
281
1161.046
K
Set
1
50
50
206.5
331.125
1367.546
80
0.508
Norfolk
B
Mar -Set
6.5
43.25
281
142,8115
K
Se t- r
1
50
50
25.4
331.125
168.2115
Subl
10.73
Wa ram
B
Mar -Set
5.5
43.25
238
2552.399
K
Se t• r
1
50
50
536.5
287.875
3088.899
Sub4
4.07
Norfolk
B
Mar -Sat
6.5
43.25
281
1144.179
K
Sept -Apr
1
50
50
203.5
331.125
1347.679
Sub7A-E
13.76
Wa ram
B
Mar -Sat
5.5
43.25
238
3273.16
K
Sept -Apr
1
50
50
688
287.875
3961.16
Sub7G
2.5
Wa ram
B
Mar-5e 1
5.5
43.25
238
5946875
K
Sept -Apr
1
50
50
125
287.875
719.6875
Tolafs: 124.068 32296.16 6203.4 38499.68
3(a) of 8

ception Area Specifications
j Tract Field Irrigated Soil 1st Crop Time to 1st Crop tst Crop Lbs NIAc Lbs N Total lbs NI 2nd Crop Time to 2nd Crop 2nd Crop Lbs NfAc Lbs N Total lbs Nfi Total Total lbs N+
I Acreage Tvoe Code Annly Yield lbs NlUnit Residual !Ac Utilized Code Anolv Yield lbs N/Unit Residual /Ac Utilized Lbs NlAc Utilized
3(b) of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i_e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results_
CROP CODE LEGEND
Qrop Code Crop
A Barley
B Hybrid Bermudagrass - Grazed
C Hybrid Bermudagrass - Hay
D Corn - Grain
E Corn - Silage
F Cotton
G Fescue- Grazed
H Fescue - Hay
I Oats
J Rye
K Small Grain - Grazed
L Small Grain - Hay
M Grain Sorghum
N Wheat
O Soybean
P Pine Trees
Lbs N utilized 1 unit yield
1.6 Ibs N 1 bushel
50 Ibs N 1 ton
50 Ibs N 1 ton
1.25 Ibs N 1 bushel
12 Ibs N 1 ton
0.12 Ibs N 1 Ibs lint
50 Ibs N 1 ton
50 Ibs N / ton
1.3 Ibs N 1 bushel
2.4 Ibs N ! bushel
50 lbs N ! acre
50 Ibs N 1 acre
2.5 Ibs N / cwt
2.4 Ibs N ! bushel
4.0 Ibs N 1 bushel
40 Ibs N 1 acre 1 yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PANT rlanimal Farm Totail r
Farrow to Wean 0.84
1400 Farrow to Feeder 1 1400
Farrow to Finish 4.1
Wean to Feeder 0.072
8000 Feeder to Finish 0.36 2880
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 4280 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 21400 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 71 acreas of land_ If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 171.2 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
'This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5of8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract Hydrant
Type
Crop
inlhr
* inches
1A
Wagram
B
0.6
1
1 B
Wagram
B
0.6
1
IC
Wagram
B
0.6
1
1D
Wagram
B
0.6
1
1 E
Wagram
B
0.6
1
1 F
Wagram
B
0.6
1
1G
Wagram
B
0.6
1
#REF! 1H
Wagram
B
0.6
1
4A
Norfolk
B
0.5
1
4B
Norfolk
B
0.5
1
4C
Norfolk
B
0.5
1
4D
Norfolk
B
0.5
1
4E
Norfolk
B
0.5
1
4F
Norfolk
B
0.5
1
4G
Norfolk
B
0.5
1
7A
Norfolk
B
0.5
1
7B
Norfolk
B
0.5
1
7C
Norfolk
B
0.5
1
7D
Wagram
B
0.6
1
7E
Wagram
B
0.6
1
7G
Wagram
B
0.6
1
8A
Norfolk
B
0.5
1
8B
Norfolk
B
0.5
1
8C
Norfolk
B
0.5
1
8D
Norfolk
B
0.5
1
Sub1
Wagram
B
0.6
1
Sub4
Norfolk
B
0.5
1
Sub7A-E
Wagram
B
0.6
1
Sub7G
Wagram
B
0.6
1
6of8

Additional Comments:
The nitrogen rate used for bermuda pasture in this plan represents
a graze/hay combination. At least one cutting of hay will be removed from these
fields each year,
7of8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: 2148/C & M II
Owner: Murphy -Brown, LLC
Manager:
Owner/Manager Agreement:
/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above, llwe know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked_
/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Murphy -Brown, LLC
Signature:
Name of Manager (if different from owner):
Signature:
Name of Technical Specialist: Dawn Williamson
Affiliation: Murphy -Brown, LLC.
Address: 2822 Hwy 24 West, PO Drawer 856
Warsaw. NC 28398
Signature:
Telephone: [phone]
Date
Date
Date
8 of 8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrierit Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recievinq crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Wastelnutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses; and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2of3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.)_ Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3of3

OAS &v ttzv ,
perator:CARROLLS #2148 County: SAMPSON Date:
Distance to nearest residence (other than owner):
1. AVERAGE LIVE•WEIGHT (ALW)
04/06/95
0.0 feet
0
sows
(farrow to
finish)
x 1417
lbs. _
1400
sows
(farrow to
feeder)
x 522
lbs. _
0
head
(finishing
only)
x 135
lbs. _
0
sows
(farrow to
wean)
x 433
lbs. -
0
head
(wean to feeder)
x 30
lbs.
Describe other
Total
Average Live Weig -
2.
3.
0
lbs
730800
lbs
0
lbs
0
lbs
0
lbs
0
730800 lbs
MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volhme = 730800 lbs. ALW x Treatment Volume(CF)/lb. ALW
Treatment Volume(CF)/lb. ALW = 1 CF/lb. ALW
Volume = 730800 cubic feet
STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0.0 cubic feet
4. TOTAL DESIGNED VOLUME
Inside top length (feet) ---------------------
Inside top width (feet) ----------------------
Top of dike elevation (feet) ------------------
Bottom of lagoon elevation (feet) ------------
Freeboard (feet) -------------------------------
Side slopes (inside lagoon) ------------------
Total design volume using prismoidal formula
McAsu�r��r�rs �.�H
�F�kc AScs Pt4�t'os
500.0,
250.0
50.0
38.0
1.0
3.0 : 1
SS/ENDI SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH
3.0 3.0 3.0 3.0 494.0 244.6 11.0
AREA OF TOP
LENGTH * WIDTH =
494.0 244.0
AREA OF BOTTOM
LENGTH * WIDTH =
428.0 178.0
120536 (AREA OF TOP)
76184 (AREA OF BOTTOM)
AREA OF MIDSECTION
LENGTH * WIDTH * 4
461.0 211.0 389084 (AREA OF MIDSECTION * 4)
CU. FT. = KAREA TOP + (4*AREA MIDSECTION) + AREA BOTTOMiJ * DEPTH/6
120536.0 389084.0 76184.0 1.8
Total Designed Volume Available = 1073974 CU. FT.

5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
500.0 250.0 125000.0 square feet
Buildings (roof and lot water)
0.0 square feet Describe this area.
TOTAL DA 12500€. 0 square feet
Design temporary storage period„to be 180 days.
5A. Volume of waste produced
Feces & urine production in gal./day per' 135 lb.' ALW 1.37
Volume = 730800 lbs. ALW/135 lbs..ALW *.1.37 gal/day 180 days
Volume = 1334928 gals. or 178466.3 cubic,feet
5B. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system.' Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume = 0.0 gallons/day * 180 days storage/7.48 gallons
per CF
Volume = 0.0 cubic feet
5c. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall = 7.0 inches
Volume = 7.0 in * DA / 12 inches per foot
Volume = 72916.7 cubic feet

.D. Volume of 25 year - 24 hour storm
Volume = 7.0 inches / 12 inches per foot * DA
Volume = 72916.7 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 178466 cubic feet
5B. 0 cubic feet
5C. 72917 cubic feet
5D. 72917 cubic feet
TOTAL 324300 cubic feet
3Y`6SUMMARY
____-...-_.- _>
Temporary storage period-- --__------_
180
days
Rainfall in excess of evaporation===
7.0
inches
25 year - 24 hour rainfall------====-____--_>
7.0
inches
Freeboard=__ _
1.0
feet
Side slopes==--
3.0
1
Inside top length —____=_---__--_>
500.0
feet
Inside top widt
250.0
feet
-Top of dike elevation------- ______________>
50.0
feet
Bottom of lagoon elevation -- --__--M---=>
38.0
feet
Total required volume- --__--______- ---_>
1055100
cu. ft.
_�•"= ` "
Actual design volume==-- _______________>
1073974
cu. f t .
Seasonal high watertable elevation (SHWT)== >
0.0
feet
Stop pumping elev.
0.0
feet
_
Must be > or = to the SHWT elev.====__--__>
0.0
feet
Must be > or = to min. req. treatment el.=>
44.0
feet
Required minimum treatment volume=====____=_>
730800
cu. ft.
Volume at stop pumping elevation=====_______>
-928264
cu. ft.
Start pumping elev,=-==___________________>
0.0-feet
Must be at bottom of freeboard & 25 yr. rainfall
Actual volume less 25 yr.- 24 hr. rainfall==>
1001057
cu. ft.
Volume at start pumping elevation=====______>
-928264
cu. ft.
Required volume to be pumped===_____•________>
251383
cu. ft.
Actual volume planned to be pumped===== =___>
0
cu. ft.
.
Min. thickness of soil liner when required==>
1.8
feet
7. DESIGNED
BY:_�� APPROVED BY:
DATE: 4�-) ` j9s DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
COMMENTS: 45 '�UILi , F7900A MA6.

IA
r
f
Z960� AHV-1 06096
(,99 q�do❑ xeA) 8 olof-; peoQ p � [ Z
L91 GZ MtVYE•96
(.'99 uldaQ XE d 910H PE90 Bt/ ,7