670084_HISTORICAL_20171231

NORTH CAROLINA .�
Department of Environmental Qual

A74 13 7AF
NCDEHR
North Carolina Department of Environment and Natural Resources
Pat McCrory John E. Skvarla, III
Governor Secretary
October 1, 2014
Morris Brinson
Brinson Farm
513 Al Taylor Rd
Richlands, NC 28574
Subject: Certificate of Coverage No. AWS670084
Brinson Farm
Swine Waste Collection,'I'reatment,
Storage and Application System
Onslow County
Dear Morris Brinson:
In accordance with your renewal request, we are hereby forwarding to you this Certificate of Coverage
(COC) issued to Morris Brinson, authorizing the operation of the subject animal waste management
system in accordance with General Permit A WG 100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for Brinson Farm, located in Onslow County, with a swine animal capacity of no greater
than the following annual averages:
Wean to Finish: Feeder to Finish: 2448 Boar/Stud:
Wean to Feeder: Farrow to Wean: Gilts:
Farrow to Finish: Farrow to feeder! Other:
If this is a Darrow to Wean or Farrow to feeder operation, there may be one boar for each 15 sows. Where
boars are unnecessary, they may be replaced by an equivalent number of sows. Any of the sows may be
replaced by gilts at a rate of 4 gilts for every 3 sows.
This COC shall be effective from the date of issuance until September 30, 2019, and shall hereby void
Certificate of Coverage Number AWS670084 that was previously issued to this facility. Pursuant to this
COC, you are authorized and required to operate the system in conformity with the conditions and
limitations as specified in the General Permit, the facility's CAWMP, and this COC. An adequate system
for collecting and maintaining the required monitoring data and operational information must be
established for this facility. Any increase in waste production greater than the certified design capacity or
increase in number of animals authorized by this COC (as provided above) will require a modification to
the CAWMP and this COC and must be completed prior to actual increase in either wastewater flow or
number of animals.
Plcase read this COC and the enclosed State General Permit carefully. Please pa y careful attention to the
record keeping and monitoring conditions in this permit. Record keeping forms are unchanged with this
General Permit. Please continue to use the same record keepinp, forms.
1636 Mail Service Center, Raleigh, North Carolina 27699-1636
Phone: [phone]Internet: htto:llvuww.ncdenr.laov/
An Equal Opportunity 1 Affirmative Actlon Employer— Made in part by recycled paper

If your Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal properly.
Per NRCS standards a 100-foot separation shall be maintained between water supply wells and any
lagoon, storage pond, or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Program for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition II.22 of the General Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Tropical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You
may find detailed watch/warning information for your county by calling the Newport/Morchead City, NC
National Weather Service office at [phone], or by visiting their website at:
littp://www.weather.pov/inhx/
This facility is located in a county covered by our Wilmington Regional Office. The Regional Office staff
may be reached at 910-796-7215. if you need additional information concerning this COC or the General
Permit, please contact the Animal Feeding Operations Program staff at [phone].
Sincerely,
for "Thomas A. Reeder
Director, Division of Water Resources
Enclosure (General Permit A WG 100000)
cc: (Certificate of Coverage only for all ccs)
Wilmington Regional Office, Water Quality Regional Operations Section
Onslow County Health Department
Onslow County Soil and Water Conservation District
WQROS Central Files (Permit No. AWS670084)
AFO Notebooks
Murphy -Brown L,LC

}
��
Amg�J�
NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Ooleen H. Sullins Dee Freeman
Governor Director Secretary
Morris Brinson
Brinson Farm
513 Al Taylor Rd
Richlands, NC 28574
February 25, 2010
\..• F d w:
Subject: Sludge Survey Testing Dates
Certificate of Coverage No: AWS670084 .
Brinson Farm
Animal Waste Management System
Onslow County .
Dear Morris Brinson:......
The Division of Water Quality (Division) received your sludge survey information on January .
28, 2010.for- the, lagoon at the;above referenced: facility. With the surveyresults, you requested
an extension of the sludge'survey requirement for the lagoon at the Brinson•Farm. Due to the
amount of.treatinent volume available;.the.Division agrees that a. -sludge survey is not needed'-:-, R
_._ . until 201.1tfor the4lagoon.
.The next sludge survey for the lagoon,at.Brinson Farm should be performed before -December_;
;> 31, 201-1.�Thank,you for, your-att ention to -this -matter. -Please call..me aV(9'1.9).,715=6937 if you.,,,t
�'. • ...,have:any questions. x. T; i . r .. r. ,.t �y����''h .. n *: ✓. - . t
Sincerely,
s _ MAR.. O
Miressa D. Garoma
'Animal Feeding Qperations Un
cc: Wilmington Regional Office, Aquifer Protection Section :?
Permit File AWS670084
1636 Mail Service Center, Raleigh, North Carolina 27699-1636
Location: 2728 Capital Blvd., Raleigh, North Carolina 27604
Phone: [phone] FAX: [phone] Customer Service: 1-877-623-6748
Inturnt: www.nrwtr rtrualitv.nm
One
NorthGarobiia
Naturally
n mull Onnnrlunity 4 A fnnntm, Action F.mnlevpr

,.r
MurphpBrown, LLC 12/7/2007 2822 Hwy 24 West
P.O. Box 856
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
'Grower(s):
Farm Name:
Morris Brinson
Brinson Farm (HWY 258); 67-84
County: Onslow
Farm Capacity:
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish 2448
Storage Structure: Anaerobic Lagoon
Storage Period:
Application Method:
>180 days .
Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients In the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops In the fields where the waste
Is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
•nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important In implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that It is applied In an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are Important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it Is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 11
RECEIVED 1 DENR 1 DWQ
A0U FFR•pp0 TFCTI0N SFCTION
MAR 18 ?Ong

This plan is based on the waste application method shown,above. If you choose to change
methods In the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste Is based on typical nutrient content
for this type of facility. In some cases you may want'to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, If carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft', tons, etc.):
Capacity Type Waste Produced per Animal Total
Farrow to Wean 1
3212 gal/yr
gallyr
Farrow to Feeder
4015 galyr
gallyr
Farrow to Finish
10585 gallyr
gallyr
Wean to Feeder
223 galyr
gallyr
2448
Feeder to Finish
986 Ral/yr
2,413,728 gal/
Total 2,413,728 gallyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs):
Capacity T e Nitrogen Produced eer Animal Total
Farrow to Wean
5.4 Ibslyr
Ibs/yr
Farrow to Feeder
6.5 Ibslyr
Ibs/yr
Farrow to Finish
26 Ibs/yr
Ibslyr
Wean to Feeder
0.48 Ibslyr
lbs/yr
2448
Feeder to Finish
2.3 lbs/yr
5,630 Ibs/ r
Total 5,630 lbalyr
Applying the above amount of waste Is a big )ob. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops Indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under Irrigation may uptake and utilize
In the normal growing season.
Total Irrigated Acreage: is
Total N Required 1st Year: 5850.00
Total N Required 2nd Year: 0.00
Average Annual Nitrogen Requirement of Crops: 5,850.00
Total Nitrogen Produced by Farm: 5,630.40
Nitrogen Balance for Crops: (219.60)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2of11

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In•the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In Interplanted fields ( i.e. small grain, etc, interseeded In bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine Inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exerclsed not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain Is planted In the fall.
The Ideal time to Interplant small grain, etc, Is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized 1 unit yield
A
Barley
1.6 lbs N 1 bushel
B
Hybrid Bermudagrass - Grazed
50 lbs N 1 ton
C
Hybrid Bermudagrass - Hay
50 lbs N 1 ton
D
Corn - Grain
1.25 lbs N 1 bushel
E
Corn - Silage
12 lbs N / ton
F
Cotton
0.12 lbs N / lbs lint
G
Fescue - Grazed
50 lbs N / ton
H
Fescue- Hay
50 lbs N / ton
I
Oats
1.3 lbs N 1 bushel
J
Rye
2.4 lbs N 1 bushel
K
Small Grain - Grazed
50 lbs N 1 acre
L
Small Grain - Hay
50 lbs N / acre
M
Grain Sorghum
2.5 lbs N 1 cwt
N
Wheat
2.4 lbs N / bushel
O
Soybean
4.0 lbs N 1 bushel
P
Pine Trees
40 lbs N / acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
requlred buffers, filter strips along ditches, odd areas unable to be Irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of11

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
In the lagoon sludge
Farm Specifications PAN! r/animal Farm Total/ r
Farrow to Wean 0.84
Farrow to Feeder 1
Farrow to Finish 4.1
Wean to Feeder 0.072
2448 Feeder to Finish 0.36 881.28
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 881.28 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 4406.4 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 14 acreas of land. if you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 35.2512 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the Intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by Initial soil moisture content, soil
structure, soli texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of Irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and Irrigation designer to ensure that an irrigation system Is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan Invalid.
*This Is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no Instance should the volume of the
waste stored In your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except In the event of the 25 year 24 hour storm.
It Is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown In the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan Invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 11

Application Rate Guide
The following Is provided as a guide for establishing application rates and amounts.
Soli Application Rate Application Amount
Tract Hvdrant Two CrOa Inlhr " Inches
T76
2
Stallings
C
0.6 1
T76
3
Stallings
C
0.5 1
T76
4
Stallings
C
0.5 1
T76
5
Stallings
C
0.5 1
T76
6
Stallings
C
0.5 1
T76
7
Stallings
C r
0.5 1
T76
8
Stallings
C
0.5 1
6 of 11

Additional Comments:
This plan revised to show acres per zone rather than acres per field.'
All other parameters remained the same as in the previous plan.'
7 of 11

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm:
Owner:
Manager:
Owner/Manager Agreement:
Brinson Farm (HWY 258); 67-84
Morris Brinson
I/we understand and will follow and Implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
1/we understand that I must own or have access to equipment, primarily Irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from, the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner:
Signature:
Morris Brinson
Name of Manager (if different from owner):
Signature:
Date
Name of Technical Specialist:
M. Kevin Weston
Affiliation:
Murphy -Brown, LLC.
Address:
2822 Hwy 24 West, PO Drawer 856
Warsaw, NC 28398
Telephone:
_(910) 293-3434
Signature: ��7 21 7
Date
8 of 11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recievinp crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9of11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist'. Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
10 of 11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste - is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
11 of 11

03/09/2009 08:48
9109892444
SOIL AND WATER
PAGE 01
March 9, 2009
4028 Ric" do Hwy
JaokowlY le, NC 2WPW
910455 4M X 3
91098s_2444
Tm "n FameN Prom Donna WaAam
FA= 910-3504m Ram 5 IndudUe Corer
Phmem 910-796-7388 Dmw Mardi 9, 20DO
am Farms 67-84 $ 07-M Marls Bdnwn ow
© ursent d rw R6Wm 11 nh C=m wm 0 P woo Repbr Q In=a
John: If there is anything else you need, feel free to call
Donna
MAR 0 9 2009
BY:
0 Page 1

03/09/2009 08:48 9109892444 SOIL AND WATER PAGE 02
5'rAT1ONARY SPRINKLER
IRRIGATION SYSTEM
�.f
Irrigation System Calibration Data Sheet for SEationary Sprinkler
Date 2.1 Farm fol -Ifq Tract No.
a. Effective sprinkler area: Lateral spacing 2 ft by sexing along lateral, ft .. r4_fli ft'
Sprinkler. Make Model Nozzle Dla. Discharge GPM
Pressure: Sprinkler _ Pump Pressure
b. Spacing between collection contalners (sprinkler spacing ` 3 (fQ/4) _ 2-0 ft
c. Number of collection containers -L(4_
d. Start of Irrigation event ', W
e. Eind of Irrigation event 'L VD
f. Duration (e-d) 2- hours
g. Operate the system, collect data, and
record on the worksheet on page 18.
Resse
h. Sum of all catches Z Inches
I 1. Average application depth (h/c) VD-7—inches
J. Precipitation rate a InchWhr
M
It. Sum of all deviations from the average catch -LZ
I. Average deviation from average application depth LLZ
m. Uniformity coefficient
m-
.:Lma
U�� X100�
fqn-m
Interpret the calibration results.
An application uniformity greater than
75 Is excellent for statlonary sprinklers.
Application uniformity between SO to
75 Is In tfie "good" range and is
acceptable for wastewater application.
Generally, an application uniformity
below 50 Is not acceptable for waste-
water Irrigation, 8 the computed OF is
less than So percent, system adjustments
are required. Contact your Irrigation
dealer or Certifled Technical Specialist
for assistance.
Wind direction
wind speed •iL_
0
90
130
0
ZlO
Z0
20
Iq
-to
OJ4
2
0
4
0
14
0
14
0
18
0
22
0
24
0....0
30
-44
L.0
.ZZ
30
10
10
112
150
19�
Q
23_,
�
Z70
31`
U
612
.444
.
40
0
1O
200
240
28^
320

03/09/2009 08.48 9109852444 SOIL AND WATER
Field Calibration Procedures ',, )
for Animal Wastewater Apolieadon Equipment
PAGE 03
Calibration Data Sheet for Stationary Sprinkler (continued)
Gauge No. Volume overlap Corrected
Deviation
Collected Adjustment volume
from Average"
2 ao—
Awl
3
L'
4 13
c�
L
b
(4
q .10
�Q
10
12
13
14 Z7.�
15 ..
,Oqa
16
17 ..,..
19
20
21
22
23
24
26
27
28
29
30
31 _..
�...,
32
'Treat all values as post".
j
�11

03/09/2009 08:48 9109892444 SOIL AND WATER 1 PAGE 04
Fleld Calibration Procedures
for Animal wastewater Application Equipment
�yArK,v--* RFD
Calibration Data Sheet for Stationary Sprinkler (continued)
Gauge No.
Volume Overlap Corrected
Deviation
Collected- Adjustment Volume
from Average'
2
3Z_
3
4
b
�3
Q#
7
LM
8
k0p .
9
3Z
10_�
00
11
Mo
+�'r
12
140
. 13k
14
$�?
15
16
LL2
17
18'�
�..
19
20,
21
22
23
24
25
26
27
28
29
30
-
31
32
'Treat all ► alues as positive.

03/09/2009 08:48
9109892444
S©IL AND WATER
PAGE 05
NO,
L I
STATIONARY SPRINKLER
IRRIGATION SYSTEM
Irrigation System Calibration Date Sheet for Stationary Sprinkler
Date. Form hZ`3iA Tact No.
a. Effective sprinklet area. Lateral spacing k_ ft by spacing along lateral. IQ ,— ft = ft'
Sprinkler. Make — ,,,— Model NaEde Dla. Discharge GPM
Pressure: Sprinkler Pump Pressure
b. Spacing between collection contalners (sprinkler spacing W (ft)/4) - 20 ft
c. Number of collection containers _.L,P_ 0 If
d. Start of Irrigation event 2,i 120
e. End of Irrigation event
f. Duration (e-d) .2=_ hours
o'o'o'aazo"obo
=o'ob'o"ouo'o
o
10
'0
1b
1
"0
"0
1210
''o
'a
'o
'o
'bo
"o
"o
�°o132o
110
g. Operate the system, collect data, and
record'on the worksheet on page I B.
h. Sum of all catches 5-17, Inches
1. Average application depth (hlc) , 351 Inches
J. Precipitation rate • m •. Indm/hr
{t)
It. Sum of all deviations from the average catch
1. Average deviation from average application depth a❑S4-
m. Uniformity coefficient
0
Interpret the calibration results.
An application uniformity greater man
75 is excellent for stationary sprinklers.
Application uniformity between So to
7S is in the "good" range and Is
acceptable for wastewater application.
Generally, an application uniformity
below 50 Is not acceptable for waste-
water irrigation. If the computed U, is
less than 50 percent, system adjustments
are required. Contact your Irrigation
dealer or Certifled Technical Specialist
for assistance.
k)
Wind direction
Wind speed.Q-
19
5 9O 13n TO 2t� 25� 79�
a •4
2 6 10 14 18 22 26 30
0 0 0 0 0 0 0.,..0
aw at
30 0 0 7,11S' 19_ 2 0 0 2731 y
4 B 120
1d aO 20 1290
30
'y 42 1 - a . R 1 -
i

O�t�F W A
r�9QG Michael F. Easley, Governor
William G. Ross Jr., Secretary
rNorth Carolina Department of Environment and Natural Resources
Coleen H. Sullins Director
Division of Water Quality
R-ECrRVEJD
November 30, 2007 D E C 0 4 RECD
Morris Brinson 13Y:
Brinson Farm
513 AI Taylor Rd
Richlands, NC 28574
Subject: Sludge Survey Testing Dates
Certificate of Coverage No. AWS670084
Brinson Farm
Animal Waste Management System
Onslow County
Dear Morris Brinson:
The Division of Water Quality (Division) received your sludge survey information on November
26, 2007. With the survey results, you requested an extension of the sludge survey requirement
for the lagoon at the Brinson Farm facility not to be required until 2009. Due to the amounts of
treatment volume available, the Division agrees that a sludge survey -is not needed until 2009.
The results of the 2009 sludge survey are to be submitted by March 1, 2010.
Thank you for your attention to this matter. If you have any questions, please call me at (919)
715-6937.
Sincerely,
Miressa D. Garoma
Soil Scientist
cc: Wilmington-RegianahOffice,.Aquifer=Protection_Section
Central Files
1 _�fi�t Carolina
dvatura!!y
Aquifer Protection Section 1636 Mail Service Center
Internet: www.ncwaterquality org Location: 2728 Capital Boulevard
An Equal Opportunity/Affirmative Action Employer-- 50% Recyded110% Post Consumer Paper
Raleigh, NC 27699-1636
Raleigh, NC 27604
Telephone: [phone]
Fax I: [phone]
Fax 2: [phone]
Customer Service: [phone]

State of North Carolina
Department of Environmen RECEIVED and Natural Resources 0�$ 3 ZOOQ
Division of Water Quality
BY. -
James B. Hunt, Jr., Governor
Bill Holman, Secretary — DEHR
CK:
Kerr T. Stevens, Director NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCE5
January 24, 2000
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Morris Brinson
Brinson Farm
513 A.I. Taylor Road
Richlands NC 28574
Subject: Conditional Approval
Animal Waste Management System
Facility Number 67-84
Onslow County
Dear Morris Brinson:
Our records indicate that your facility was conditionally certified in order to fulfill the requirements
of completion of your Certified Animal Waste Management Plan Certification. - This letter is to inform you
of your unresolved conditional approval status. Any facility receiving a conditional approval must notify
Division of Water Quality (DWQ) in writing within 15 days after the date that the work needed to resolve the
conditional certification has been completed. Any failure to notify DWQ as required, subjects the owner to
an enforcement action. As of December 6, 1999, we have no record of any information from you, advising
us of the status of your conditional approval. Therefore, please fill out the attached form and have your
technical specialist and landowner sign the form in the appropriate areas.
The completed farm must be submitted to this office on or before 45 days of receipt of this letter.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or liability
for failure to provide DWQ with proper notification of your conditional certification status or possible failure
to comply with the requirement to develop and implement a certified animal waste management plan by
December 31, 1997.
If you have any questions regarding this letter, please do not hesitate to contact me at [phone]
extension 571.
Sincerely,
Sonya L. Avant
Environmental Engineer
cc: Wilmington Regional Office
Onslow County Soil and Water Conservation District
Facility File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Aitirmative Action Employer 50% recycled110% post -consumer paper

State of North Carolina
Department of Environment T,10 R
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor JAIN 0 3 mo I�
Bill Holman, Secretary CDENR
LBY:
Kerr T. Stevens, Director NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
December 30, 1999
Morris Brinson
Brinson Farm
513 A.I. Taylor Road
Richlands NC 28574
Subject: Fertilizer Application Recordkeeping
Animal Waste Management System
Facility Number 67-84
Onslow County
Dear Morris Brinson:
This letter is being sent to clarify the recordkeeping requirement for Plant Available Nitrogen (PAN)
application on fields that are part of your Certified Animal Waste Management Plan.
In order to show that the agronomic loading rates for the crops being grown are not being exceeded, you
must keep records of all sources of nitrogen that are being added to these sites. This would include nitrogen
from all types of animal waste as well as municipal and industrial sludges/residuals, and commercial fertilizers.
Beginning January 1, 2000, all nitrogen sources applied to land receiving animal waste are required to
be kept on the appropriate recordkeeping forms (i.e. IRR1, IRR2, DRY1, DRY2, DRY3, SLUR1, SLUR2,
SLDI , and SLD2) and maintained in the facility records for review. The Division of Water Quality (DWQ)
compliance inspectors and Division of Soil and Water operation reviewers will review all recordkeeping during
routine inspections. Facilities not documenting all sources of nitrogen application will be subject to an
appropriate enforcement action.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Ms. Sonya Avant of the
DWQ staff at [phone] ext. 571.
Sincerely,
Kerr T. Stevens, Director
Division of Water Quality
cc: Wilmington Regional Office
Onsiow County Soil and Water Conservation District
Facility File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10%a post -consumer paper

State of North Carolina
Department of Environment
end Natural Resources • = y r
y�
Division of Water Quality ` ' �-'-`�'�`'
James B. -Hunt, Jr., Governor '
Wayne McDevitt, Secretary�NCD
A. Preston Howard, Jr., P.E., Director _
NORTH {CAROUNA •DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
December 28, J998 ; ,, '• ;
Morris Brinson
Brinson Farm
.513 A.I. Taylor Rd
F'.'+� f •4 9A9 4 };h�' 1 Y i
Richlands NC 28574
Subject: Certificate of Coverage No: 0084
AWS67
A .
' Brin''son Farm
` Swine Waste Collection, Treatment,
Storage and Application System,•,
.Onslow County -
Dear Morris Brinson:
h • 1
In 'accordance with your application received '.on Octob14,1 1998, we ,are forwarding? this` ,
Certificate of Coverage (COC) issued to Morris Brinson; authorizing-the'operation of the subject animal
waste collection, treatment, storage and land application: systems in.`:accordance 'With General Permit
AWG 100000. 'This approval shall consist of the operation of this 'system including, but not limited to.
.
the management of animal waste from the Brinson Farm, located in °Onslow.County, .with an animal
capacity of no greater than 2448 Feeder to Finish and the application to land as specified in the Certified
Animal Waste Management Plan (CAWMP).:,
The COC shall be effective from the date of issuance until April 30, 2001%Pursuant to� this'COC, '
you are authorized and required to operate the system "in conformity 'with`the •condi ' ' ns and limitations
as specified in the. General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data, and
operational information must be established for this farm. Any increase in waste production greater than_= . .,_
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP, and this COC and shall be completed prior .to,,
actual increase in either wastewater flow or number of animals:
Please be advised that any violation of the terms and conditions specified in this COC, the General
Permit or the CAWMP may result in the revocation of this COC,; or penalties in accordance with NCGS
143-215.6A'through 143-215.6C including civil penalties; criminal penaltie5,'aiid injunctive r"elief.'
Upon notification by the Division of this COC'sLLexpiration, you"sliall apply for its "renewal T'� This
l
request shall be made within 30 days of notification by the Division.
_'•. _ �•..: :..z '� P.++,`µ��l'�.>���+ry,=r..r. �x �rry,�f ! �1 '•7L f 3.SM,+c5
This `COC is not automatically trarisferable4..,A'. name/ownership ,change application must be,w,
submitted to the DW prior to a name change or change in'ownershi .:.
IF any parts, requirerrients, or limitat ons`coritained�iinhis CO6a uh' c e idble; ou h- et
P y , r....
right to apply for an individual non -discharge permit by contacting the engineer 'listed belovir� for ^'
�t
y .;. P.O.'Box 29535, Raleigh, -North Carolina 27626 0535 57releph6ne 919.733.7015 `=SAX 919-733.2496 ��; -•
..L,. An'Equal Opportunity Affirmative Action Employer- `50% recycled/ 10% po`st-consumer paper,
s iT , -'f . - rl . • _"}u' 4 .- „. -. 1. x 7 T ,yN,i f
• A. +' , �: t,. ' � fir, ` J 'fit' ' 1 r ,Y r , �_

Certificate of Coverage AWS670084
Brinson Farm
Page 2 ... 1
}d.
information on this process. Unless such a' request is made within 30 days, this COC shall be final and ^'
binding. ` ...... .
The subject farm is located in the Wilmington Regional Office. The Regional Office Water:
Quality Staff may be reached at [phone]. If you need additional information concerning this
COC or the General Permit, please contact J R Joshi at [phone] ext. 363.
Sincerely,
-.
..�
• A. Preston H6ward,4r.; P.E.
•
- ; L G. c} �''~' -'
- ... •'
dr
cc:
(Certificate of Coverage only for all cc'S)
_.
Onslow County Health Department =
`
Wilmington Regional Office, Water Quality Section
Onslow County Soil and Water Conservation District
Permit File -Central Files
Permit File-NDPU

r
State of North Carolina
Department of Environment and Natural Resources RECEIVED
Division of Water Quality WATER QUALITYSE00N
Non -Discharge Permit Application Form �y
(THIS FORM MA Y BE PHOTOCOPIED FOR USE AS AN ORIGINAL) 'Aft.1 14 1998
General Permit - Existing Liquid Animal Waste Operations
Non -Discharge Permitfing
The following questions have been completed utilizing information on file with the Division. Please
review the information for completeness and make any Corrections which are appropriate. If a
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
1. GENERAL INFORMATION:
1.1 Facility Name: Brinson Farm
1.2 Print Land Owner's name: Morris Brinson
1.3 Mailing address: 513 A.I. Taylor Rd
City, State: Richlands NC lip: 28574
Telephone Number (include area code): 910-324-5641
1.4 County where facility is located: Onslow
1.5 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a
copy of a county road map with the location of the farm identified): From Kenansville, take NC 24E into Onslow Co.,
turn left onto SR 1230 (Haw Branch Rd) Go 2.8 miles and turn rt onto US 258, go 0.5 miles to farm entrance on rt.
1.6 Print Farm Manager's name (if different from Land Owner):
1.7 Lessee's/ Integrator's name (if applicable; please circle which type is listed): Murphy Family harms
1.8 Date Facility Originally Began Operation:
1.9 Date(s) of Facility Expansion(s) (if applicable):
2. OPERATION INFORMATION:
2.1 Facility No.: 67 p (county number); $4 (facility number).
2.2 Operation Descrii nSwine operation
FeeTr to Finish
2448- Certified Design Capacity
Is the above information correct? =yes; ` �Ino. If no, correct below using the design capacity of the facility
The "No. of Animals" should be the maximum numc—r or which the waste management structures were designed.
Type of Swine
0 Wean to Feeder
0 Feeder to Finish
0 Farrow to Wean (# sow)
0 Farrow to Feeder (# sow)
0 Farrow to Finish (# sow)
No. of Animals Type of Poultry No. of Animals
0 Layer
Other Type of Livestock on the farm:
0 Non -Layer
0 Turkey
Type of Cattle No. of Animals
0 Dairy
0 Beef
No. of Animals:
FORM: AWO-G-E 5/28/98
Page 1 of 4 67 - 84

2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): . 17 ; Required Acreage (as listed in the AWMP): 17
2.4 Number of a oon storage ponds (circle which is applicable):
2.5 Are subsurface drains present within 100' of any of the application fields? YES or N (please circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES or O (please circle one)
2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, ndards, etc.) (Swine Only)
YE or NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited? V�CC 1�—
What was the date that this facility's land application areas were sited? �0, a-S;—
3. REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Applicants Initials
Waste Operations;
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
Q{�
does not have a CAWMP, it must be completed prior to submittal of a general permit
application for animal waste operations.
The CAWMP must include the following components:
3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application.
3.3.4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application field.
3.3.8 The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.3.10 A site schematic.
3.3.11 Emergency Action Plan,
3.3.12 Insect Control Checklist with chosen best management practices noted.
3.3.13 Odor Control Checklist with chosen best management practices noted.'
3.3.14 Mortality Control Checklist with the selected method noted.
3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility.
3.3.16 Operation and Maintenance Plan.
If your CAWMP includes any components not shown on this list, please include the
additional components with your submittal.
FORM: AWO-G-E 5/28/98 Page 2 of 4 67 - 84

i.
RECEIVED
WATER QUALITY SECTION
Facility Number: 67 - 84
Facility Name: Brinson Farm
4. APPLICANT'S CERTIFICATION:
1. �nC>r f I s by" f'�S o n
'or,T 1 41998
Eton-DischmUe Permitting
(Land Owner's name listed in question 1.2), attest that
this application for ]C'� f\ � A-c ►-c'M (Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned to me as iplete.
e /- _
Signature
5. MANAGER'S CERTIFICATION: (complete only if different from the Land Owner)
(Manager's name listed in question 1.6), attest that this
application for {Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. 1 understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned as incomplete.
Signature
Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
FORM: AWO-G-E 5/28/98 Page 3 of 4 67 - 84

DIVLS ON OF WATER QUALM REGIONAL OFFICES (IM)
Asbm1Je R*gioml WQ Sgftvism
99 woodfin Place
Ashevilk.NC 29MI
CM) 251-6208
Fax [phone]
Avery Mawr
Btmooaft Madison
Bu a McDowell
Caldwell Mitchel]
Cb - --- - Palk
Clay Rutberford
yam Swain
Haywood Transylvania
Hendmm Yancey
labon
Fayetteville Regional WQ Supervisor
Wachovia Building, Suite 714
Fayetteville, NC 28301
[phone]
Fax [phone]
Wasbiagtan Regional WQ Swe visor
943 WasWagm Squam Mall
WadbgM NC 27869
(919) 94&"l
Fax [phone]
Boack t lopes
sortie LOW
Craven
Pasquatok
Caratuck
Paquimaas
D=
Pitt.
Clraem
washi om
Hertford
Wayne
Hyde
MoasrsvMe Rcg1md WQ Svpmv1m
919 North Main Street
Mooresville, NC 28115
[phone]
Fax (104) 663-WW
x"SbReeloodwQSWUNhOor
sm soma Dr.
Raloigh. NC 27611
[phone]
Fax [phone]
Clhadu m Nash
Dmrham Nadu
Bdgecambe Cltaage
Fhmklin Pert�on
ckwsville Vaaoe
Halifax ware
ynhlam wamn
Lee Wilson
Wilmington Region. WQ Sopmvi:ar
127 Cardiaal Drive Extepsian
Vrd min M NC 28405-3845
[phone]
Fax [phone]
Anson Moore Alexander Lincoln Brunswick New Hanover
Bladen Richmond Cobs= Modk aaburg C*WM Onslow
CumbaVnd Robeson Catawba Rowan Columbus Peoder
Harnett sampson C3ove w Stanly Duplia
Hake Sootisod Coon Union
Idomgommy be" -
Winston-Salem Regional WQ Stav=
585 Wmgbumm Stmat
Winston-Salem. NC 27107
[phone]
Fax [phone]
Alamance
Rockingham
Allq*w
Randolph
Ache
Stakes
C,aswdl
Sorry
Davidson
wataoga
Davie
Wilkes
Farmyth
Ciailfad
Yadkdn
FORM: AWO-G-E 512WS
Page 4 d4

RECEIVED
Animal Waste Management Plan CertificatioWi Qu"SECTtON
(Please tvpa-eri*nt all information that does not require a
Existing or or: Expanded (please circle one) "''` 199$
General Information: on-Disch
Name of Farm: lddr� Fin Facility No: a Pemutbn8
Owner's Name: less Brins n Phone No: [phone]
Mailing Address: 513 A. I. 'Tayy Rcad Rom, N-_ 28574
Farm Location: Fourteen Digit Hydrologic Unit: 03030001010010
Latitude and Longitude: V 56' 35' / 77° 36' 41" County: Orslcw
Please attach a copy of a county road map with location identified and describe below
(Be specific: road names, directions, milepost, etc.): F!n YarersvMe, Make N-_ 24 E irtn Crrdcw (b.
t= left cr to SR 1230 (Hw Btu Rd) (b 2.8 mils aril t = Rt crto [S 258 GD 0.5 at It to faun Cr
Rt
Operation Description:-
Type of Swine No of Animals Type of Poultry No of Animals Type of Cattle No of Animals
_ Wean to Feeder Layer _Dairy
x Feedeer to Finish 2448 Pullets _Beef
Farrow to Wean
_ Farrow to Feeder
Farrow to Finish Other Type of Livestock: Number of Animals:
Existing and Expandlttg Operation'Anly
lZeglsirafion late, (Date vn which farm:applxed for. registration};
Acreage Available for Application: 7 Required Acreage: 17
Number of Lagoons/Storage Ponds: 1 Total Ca • bbU42 Cubic Feet W)
Are subsurface drains present on the farm: YES o NO (please circle one)
###t#t**:s+FR#:t�K###�K#t#ttt##Mt###Rttxlettf#asxf�#�k#*#:I�yr�tt#i tf�lcff#f#�k#�rRf#t�k###f�Kf�kRfcttff#R#Ac�kl�kKf
Owner /Manager Agreement
I (we) verify that all the above information is correct and will be updated upon changing. I (we) .
understand the operation and maintenance procedures established in the approved animal waste
management plan for the farm named above and will implement these procedures. I (we) know that any
expansion to the existing design capacity of the waste treatment and storage system or construction of
new facilities will require a new certification to be submitted to the Division of Environmental
Management before the new animals are stocked. I (we) understand that there must be no discharge of
animal waste from the storage or application system to surface waters of the state either directly through
a man-made conveyance or from a storm event less severe than the 25-year, 24-hour storm and there
must not be run-off from the application of animal waste. I (we) understand that run-off of pollutants
from lounging and heavy use areas must be minimized using technical standards developed by the
Natural Resources Conservation Service. The approved plan will be filed at the farm and at the office of
the local Soil and Water Conservation District. I (we) know that any modification must be approved by a
technical specialist and submitted to the Soil and Water Conservation District prior to implementation. A
change in land ownership requires written notification to DEM. or a new.certification (if the approved
plan is changed) within 60 days of a title transfer.
Name of Land Owner: M=S Brimm
Signature: _0M���,// _ __ _ Date:
Name of Manager (if different from owner): ^ _
Signature: Date:
AWC -- April 24, 1996

Technical Specialist Certification
I As a technical specialist designated by North Carolina Soil and Water Conservation Commission
pursuant to 15A NCAC 6F .0005, I certify that the animal waste management system for the farm named
above has an animal waste management plan that meets or exceeds standards and specifications of the
Division of Environmental Management (DEM) as specified in 15A NCAC 2H.0217 and the USDA -
Natural Resources Conservation Service (NRCS) and/or the North Carolina Soil and Water Conservation
Commission pursuant to 15A NCAC 2H.0217 and 15A NCAC 617.0001-.0005. The following elements
are included in the plan as applicable. While each category designates a technical specialist who may
sign each certification (SD, S1, WUP, RC,1), the,technical specialist should only certify parts for which
they are technically competent.
II. Certification of Design
A) Collection, Storage, Treatment System
Check the appropriate box
Existing facility without retrofit (SD or WUP)
. Cob AND
Storage volume is adequate for operation capacity; storage capability consistent
1M�/
with waste utilization requirements.
ssi
a- New, expanded or retrofitted facility (SD)
SEAL
Animal waste storage and treatment structures, such as but no limited to collectio
14985
systems, lagoons and ponds, have been designed to meet or exceed the minimum
standards and specifications.
Name of Technical Specialist (Please Print): J. Neal Tucker
��•�•'
Affiliation: Murphy Family Fauns
Address (Agency) lO Bic 759 twee HU1, rC hone No.: 910 289-6439 Ext. 4717
Signature: Date:�Z3
B) Land Application Site (WUP)
The plan provides for minimum separations (buffers); adequate amount of land for
waste utilization; chosen'crop is suitable for waste management; hydraulic and
nutrient loading rates.
Name of Technical Specialist (Please Print): M. revil
Westcn
Affiliation: fly F.1131S
Address (Agency): M B:X 759 R:ee Hill, N�284-%Fhone No.: (910)2B9-W9 5t. 426
Signature: _ �✓l ...,�:.l%s Date: gir, 4-
C) Runoff Controls from Exterior Lots
Check the appropriate box
Q- Facility without exterior lots (SD or WUP or RC)
This facility does not contain any exterior lots.
Facility with exterior lots (RC)
Methods to minimize the run off of pollutants from lounging and heavy use areas
have been designed in accordance with technical standards developed by NRCS.
Name of Technical Specialist (Please Print): M. Fe in Weser
Affiliation: tmY FantlY Fans -
Address (Agency): >FO BOc 759 RDse'HM tC 2B458 Phone No.: [phone] Dct. 4629
Signature: "! Date:
AWC--April 24, 1996
ra

D) Application and Handling Equipment
Check the appropriate box
Existing facility with existing waste application equipment (WUP or I)
Animal waste application equipment specified in the plan has been either field
calibrated or evaluated in accordance with existing design charts and tables and is
able to apply waste as necessary to accommodate the waste management plan:
(existing application equipment can cover the area required by the plan at rates not
to exceed either the specified hydraulic or nutrient loading rates, a schedule for
timing of applications has been established;{required buffers can be maintained and
calibration and adjustment guidance are contained as part of the plan).
1- New or expanded facility; or existing facility without existing waste application
equipment (I)
Animal waste application equipment specified in the plan has been designed to
apply waste as necessary to accommodate the waste management plan; (proposed
application equipment can cover the area required by the plan at rates not to
exceed either the specified hydraulic or nutrient loading rates; a schedule for
timing of applications has been established; required buffers can be maintained;
calibrations and adjustment guidance are contained as part of the plan).
Name of Technical Specialist (Please Print): M- Kevin Wa5l=
Affiliation: Mm#y FanUy R=z
Address (Agency): lO B:X 759 Fcsa Hill. X 28458 Phone No.:
Signature: ' Date: f
Ill. Certlflcatlon Of lnstallation
A) Collection Storage, Treatment Installation
New, expanded or retrofitted facility (SI)
Animal waste storage and treatment structures, such as but no limited to
lagoons and ponds, have been installed in accordance with the approved plan to
meet or exceed the minimum standards and specifications.
For existing facilities without retrofits, no certification is necessary.
Name of Technical Specialist (Please Print): 1''l- inn Wastan
Affiliation: nxpiy wily hats
Address (Agency): 170 BcK 759 Fcae HLU,284-58 Phone No.: [phone] EKL 4629
Signature: �1 Z1,,.d _ -_ =
Date: 4fG
--- te--,
AWC -- April 24, 1996

B) Land Application Site (WUP)
Check the appropriate box
The cropping system is in the place on all land as specified in the animal waste management plan.
L3' Conditional Approval: all required land as specified in the plan is cleared for planting; the cropping
system as specified in the waste utilization plan has not been established and the owner has
committed to establish the vegetation as specified in the plan by 197
(month/day/year); the proposed cover crop, is appropriate for compli nce with the waste utilization
plan.
Also check this box if appropriate
if the cropping system as specified in the plan can not be
established on newly cleared land within 30 days of this
certification, the owner has committed to establish an
interim crop for erosion control;
Name of Technical Specialist (Please Print): M- Fevin Wesbm
Affiliation: n3r�y Firs
Address (Agency): 759 lea HM lC 78458 Phone No.: (910)289-6M kNt. 4629
Signature: _ _ Date: _4 1d /IP4-
This following signature block is only to be used when the box for conditional approval in III. 8 above
has been checked.
I (we) certify that I (we) have committed to established the cropping system as specified in my (our)
waste utilization plan, and if appropriate to establish the interim crop for erosion control, and will
submit to DEM a verification of completion from a Technical Specialist within .15 calendar days
following the date specified in the conditional certification. I (we) realize that failure to submit this
verification is a violation of the waste management plan and will subject me (us) to an enforcement
action from DEM.
Name of Land O r: o «s s R
Signature:-dL%�f�=
Name'of Manager (if different from owner):
Signature:
0 Runoff Controls from Exterior Lots_(RC)
Date:
Date:
Facility_with exterior lots
Methods to minimize the run off of pollutants from Iounging and
heavy use areas have been installed as specified in the plan.
For facilities without exterior lots, no certifcation is necessary.
blame of Technical Specialist (Please Print):
Affiliation:
Address (Agency): Phone No.:
Signature: Date:
AWC -- ApriI 24, 1996
4

D) Application and Handling Equipment Installation (WUP or I)
Check the apptppni Ue block
Animal waste application and handling equipment specified in the plan is on site and ready
for use; calibration and adjustment materials have been provided to the owners and are
contained as part of the plan.
Animal waste application and handling equipment specified in the plan has not been
installed but the owner has proposed leasing or third party application and has provided a
signed contract; equipment specified in the contract agrees with the requirements of the
plan; required buffers can be maintained; calibration and adjustment guidance have been
provided to the owners and are contained as part of the plan.
0' Conditional approval: Animal waste application and handling equipment specified in the
plan has been purchased and will be on site and installed by
&v 9 7 (month/day/year); there is adequate storage to
hold the waste until the equipment is installed and until the waste can be land applied in'
accordance with the cropping system contained in the plan; and calibration'and adjustment
guidance have been provided to the owners and are contained as part of the plan.
Name of Technical Specialist (Please Print):
Affiliation: M=hy - Faam
Address (Agency): > 13::5c 759 Free H . S
Signature: .a► .
M. Kevin wesbm
Phone No.:
Date: r/.
The following signature block is only to be used when the box for conditional approval in III D above has
been checked.
I (we) certify that I (we) have committed to purchase the animal waste application and handling
equipment as specified in my (our) waste management plan and will submit to DEM a verification of
delivery and installation from a Technical Specialist within IS calendar days following the date specified
in the conditional certification. I (we) realize that failure to submit this certification is a violation of the
waste management plan and will subject me (us) to an enforcement action from DEM.
Name of Land Owner:
Signature:
Name of Manager(if different from owner):
Signature:
Date:
Date:
Please return the completed form to the Division of Environmental Management at the following address:
Department of Environment, Health, and Natural Resources
Division of Environmental Management
Water Quality Section, Compliance Group
P. O: Box 29535
Raleigh, NC 27626-0535
Please also remember to submit a copy of this form along with the complete Animal Waste Management
Plan to the local Soil and Water Conservation District Office and to keep a copy in your files with your.
Animal Waste Management Plan.
AWC -- April 24, 1996

Animal Waste Management Plan Certification
ATTACHMENT A
to
FORM AWC APRIL 24L1996
General Information:
Name of Farm: Ed"sm F' . Facility No: -
Owner(s) Name: 13ris Brix= Phone No: [phone]
Mailing Address: 513 A. I. Taylor Road RidJ�, 1U 28574
II. Certification of Design
D.) Application and Handling Equipment
New or expanded facility; or existing facility without existing waste application
equipment (WUP or I)
Animal waste application equipment specified in the plan has been either Meld
calibrated or evaluated in accordance with existing design charts and tables and is able
to apply waste as necessary to accommodate the waste management plan: (application
equipment can cover the area required by the plan at rates not to exceed either the
specified hydraulic or nutrient loading rates, a schedule for timing of applications has
been established; required buffers can be maintained and calibration and adjustment
guidance are contained as part of the plan).
Name of Technical Specialist (Please Print): M. Kevin Weston
Affiliation: Murphy Family Farms
Address (Agency): PC Box 759 Rose Hill, NC 28458 '
Phone No.: [phone] Ext. 4629
Signature: jr1w��,. - Date: e%1p4
If the technical specialist chooses to use this Attachment to certify the design of a new
or expanded facility; or existing without existing waste application equipment, it must
be attached to the completed Animal Waste Management Certification Form (AWC-
April 24, 1996). The technical specialist must also write in the words "See Attachment"
in Part 11. D. Of the Certification Form to notify the review agencies that the Attachment
has been used.
This Attachment will not be acceptable past the effective date of the new NCRS
Technical Standards.
AWC - May 3, 1996

,1 ��
x?.,µ�,.S,.n...........w,
M 1
�l:.:w%L.krwMwL.... ... '•,.s., .. .. '�t..••,�'.`.:iiC"ii-:�2.•Aw...C��':,�.:tinn�Sf:�
Producer: r' f , wgrRFECUAELIT SED oN
'S'i3 A.L. iR let Ro��
Location: R,,>.,i"'JS, V,-.F 5-1 -t OrT 14 1998
Telephone: 6 x:03 a w- 5b 0 l Non -Discharge permitmng
Type Operation: F e d, - ;, ; 5
Number of Animals: a 1-1 4
(Design Capacity)
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface and/or groundwater. The plant nutrients in the animal waste should
be used to reduce the amount of commercial fertilizer required for the crops in the fields
where the waste is to be applied. This waste utilization plan uses nitrogen as the limiting
nutrient. Waste should be analyzed before each application cycle. Annual sod tests are
strongly encouraged so that all plant nutrients can be balanced for realistic yields of the
crop to be grown.
Several factors are important in implementing your waste utilization plan in orderto
rnadmi 7e the fertilizer value of the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply more nitrogen than the crop
can utilize. Soil types are important as they have different infiltration rates, leaching
potentials, cation exchange capacities, and available water holding capacities. Normally
waste shall not be applied to land eroding at greater than 5 tons per acre per year. With
special precautions, waste may be applied to land eroding at up to 10 tons per acre per
year. Do not apply waste on saturated soils, when it is raining, or when the surface is
frozen. Either of these conditions may result in runoff to surface waters which is not
allowed under DEM regulations. Wind conditions should also be considered to avoid drift
and downwind odor problems. To maximize the value of nutrients for crop production
and to reduce the potential for pollution, the waste should be applied to a growing crop or
applied to bare ground not more than 30 days prior to planting. Injecting the waste or
disking -will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. Acreage requirements should be based on the waste analysis
report from your waste management facility. Attached you will find information on
proper sampling techniques, preparation,'aad transfer of waste samples to the lab for
analvsis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A
NCAC 2H.0217 adopted by the Environmental Management Commission.

I
v1
Amount of Waste Produced Per rear(gallons, tons etc.
DYyi 3 � '/Dr' for�3
animals X I—Ip.), waste/animal/year =�0 l (Aza0 waste/year.
Amount of Plant Available Nitrogen (PAN) Produced Per Year
Qyq$ animals X�J Is. PAN/animal/year 5630 lbs. PAN/year. (PAN from N. C. Tech.
Guide Std. 633)
Applying the above amount of waste is a big job. You should plan time and have
appzopriate equipment to apply the waste in a timely manner.
The following acreage wfil be needed for waste application based on the crop to be grown
and surface application:
Table P ACRES OWNED BY PRODUCER
Tract Field Sod Crop Lbs. N Acres Lbs. N Month of
M No_ Tvne Per Ac_ * UtEzed Annlication
Total I51 a G 1
* This N is from animad waste only. If nutrients from other sources such as comrracial
fertiliser are applied* they must be accounted for. N must be based on realistic yield
expectation
NOTE: The applicator is cautioned that P and .If maybe over,applied while meeting the N
requirements. Beginning in 1996 the Coastal Zone Management Act will require fanners in .
some eastern counties of North Carolina to have a nutrient n=agement plan that addresses
all nutrients. This plan only addresses Nitrogen.

I
Table 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(,Ag:eunent with adjacent landowtier must be attached)
(Rewired only if operator does not own
adequate land. [see Required SpeciScation 21)
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
* See footnote for Table 1.
Totals from above Tables
Acres Lbs. N
Utilized
Table I
Table 2
Total
Amount of
Surplus D
!
eftcit
�i � 0
-1. L-
-1 DU
oduced
C 3
O
NOTE. The Waste Utilization Plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient rich and will
require precautionary measures to prevent over application of nutrients or other
element
3

� m-- -, mm �
' '^�����]�r.LrSrr.rL"+�'+iw
See attached map showing the fields to be used far the utilization of waste water.
Application of Waste by Irrigation
Field Soil Type Crop Application Applicarion
No. Rate In/Hr Amount (In.
8 e ewA465
= TABLE IS NOT == LF WAM IS NOT BMNGAPMM BY IRRIGATION. HOWEVERA SMMARTAME WILL
BE 'x,=E 7 FOR DRY Lit= OR SLURRY.
Your facility is designed fora ' days of temporary storage and the temporary storage
must be removed on the average of once every MONTHS. In no instance shout
the volume of waste being stored in your structure exceed Elevation j et Inaor� ��
��a�
Call the local Natural Resources Conservation Service (formerly Soil Coits�ery n
Service) or Soil and Water Conservation District office a$er you receive the waste
analysis report for assistance in determining the amount per acre to apply and the proper
application rate prior to applying the waste.
4

�kwT¢uri , -1-1 ,=s �.:.:.:.M
REQUMED SPECFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff drift, manmade
conveyances, direct application, or direct discharge during operation or land
application. Any discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the producer either owns or has
an agreement for use of adequate land on which to properly apply the waste. If the
producer does not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is withia a reasonable
proximity, allowing him/her the use of the land for waste application. It is the
resp onsbiiity of the owner of the facUity to secure an update of the Waste Utsffaation
Plan when there is a change is the operation, increase in the number of animals
method of utilization, or available land_
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic
crop yields based on soil type, available moisture, historical data, climatic conditions,
and level of management, unless there are regulations that restrict the rate of
application for other nutrients. '
4. Animal waste shall be applied to land eroding less than 5 tons per acre per year.
Waste may be applied to land that is eroding at 5 or more tons, but less than 10 tons
per acre per year providing grass flter strips are installed where ruuoffleaves the field
(See FOTG Standard 393 - Filter Strip).
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be sod
incorporated on conventionally tilled cropland. When applied to conservation tined
crops or grassland, the waste may be broadcast provided the application does not
occur during a season prone to flooding. (See "Weather and Climate in North
Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
runoff does not occur offsite or to surface waters and in a method which does not
cause drift from the site during application. No ponding should occur in order to
control odor or flies.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.

UQUMED SPECIFICATIONS
(continued)
9. Animal waste shall be applied on actively growing crops is such a manner that the
crop is not covered with waste to a'depth that would inhibit growth. The potential for
salt damage from animal waste should also be considered.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste nutrient loading rates on these soils should
be held to a minimum and a suitable winter cover crop planted to take up released
nutrients. Waste shall not be applied more than 30 days prior to planting ofthe crop
or forages breaking dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the
following: The outer perimeter of the land area onto which waste is applied from a
lagoon that is a component of a swine farm shall be at least 50 feet from any residential
property boundary and from any perenttiak stream or river (other than an irrigation
ditch or canal Animal waste other than swine waste from facilities sited on or after
October 1, 1995), shall not be applied closer than 25 feet to perennial waters. (See
Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14. Waste shall be applied in a scanner not to reach other property and public right-of-
ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands
by a discharge or by over -spraying. Animal waste may be applied to prior converted
wetlands provided they have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc.,
shall not be discharged into the nairnal waste management system.
6

„.„.,.\.::.0 1 a ..,..::i?,;:<'. `'.b.Y::i s�Si:•:,;ew�ati:�'�..,......•?.•'^»...s;:::Y� •.t.Ve..,,..... :t� zWME
....,,...Y�...,A+ui::�luai.:t«:::;;<:�:a+:;xta'
REQUIRED SPECIFICATIONS
(continued)
13. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan” which will elbn ate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks, and spills. A regular maintenance checklist should
be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops for
direct human consumption. However, if animal waste is used on crops for direct
hTfr*+an consumption it should only be applied preplant with no further applications of
animal waste during the crop season.
21. IE#dy visible markers shall be installed to mark the top and bottom elevations of the
te=orary storage (pumping volume) of all waste treatment lagoons. Pining shall
be managed to maintain the liquid level between the markers. A marker will be
required to mark the maximum storage volume for waste storage ponds.
22. Waste shall be tested within 69 days of utilization and soil shall be tested at least
annually at crop sites where waste products are applied. Nitrogen shall be the rate-
determft�ing element. Zinc and copper levels in the soils shall be monitored and
alternative crop sites shall be used when these metals approach excessive levels. pH
shall be adjusted for optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry waste application records
shall be maintained for three (3) years. Waste application records for all other waste
shall be maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina regulations.
7

ION -
REWm��Y i wah w.ttwk2W��A i.l wr'Y w�i�S C�Yi YAW ' �ry �' J
WASTE UTILIZATION PLAN AGREEMENT
1Vame of Farm: &(-SG in rc"r
Owner/Manager Agreement
f (we) understand and wdl follow and implement the specification and the operation and
maintenance procedures established is the approved animal waste utffization plan for the
farm named above. I (we) ka.ow that any expansion to the wdstmg design capacity ofthe
waste treatment and storage system or construction of new facilities will require anew
certification to be submitted to the DMsiou of Environment Management (DEMj before
the new animals are stocked. I (we) also understand that there must be no discharge of
animal waste from this system to surface wasters of the state from a storm eveat less
severe than the 25-year, 24-hour storm. The approved plan will be filed on -site at the
farm office and at the office of the local Soil and Water Conservation District and wfil be
available for review by DEM upon request.
Name of Facility Owner: A� o , �• S
(Please print)
Signature: �)'ivG' y Date: i v l 1 9 7
Name of Manager(If different from owner):
Signature: Date: rr
Name of Technical S ecialist (Please nr) ram. 1 c S Tez 2
P Pn
Affiliation: 'A
� -k rU '^ter I- 0.
Address (Agency):
r4 r H /V �TJ
� 1 �� Signature: te: r

M
RECEIVED
WATFR n+ 1AI)TY SFOTiON
System Calibration wT 1 d lylo
Mon -Discharge Permitting
Information presented in manufacturer's charts are based on average operation
conditions with relatively new equipment. Discharge rates and application rates
change over time as equipment gets older and components wear. In particular,
pump wear tends to reduce operating pressure and flow. With continued use,
nozzle wear results in an increase in the nozzle opening which will increase the
discharge rate while decreasing the wetted diameter.
You should be aware that operating the system differently than assumed in the
design will alter the application rate, diameter of coverage, and subsequently the
application uniformity. For example, operating the system with excessive pressure
results in smaller droplets, greater potential fnr drift, and accelerates wear of the
sprinkler nozzle. Clogging of nozzles can result in pressure increase. Plugged
intakes or crystallization of mainlines will reduce operating pressure. Operating
below design pressure greatly reduces the coverage diameter and application
uniformity.
For the above reason, you should calibrate your equipment on a regular basis to
ensure proper application rates and uniformity. Calibration at least once every
three years is recommended. Calibration involves collecting and measuring flow at
several locations in the application area. Any number of containers can be used to
collect flow and determine the application rate. Rain gauges work best because
they already have a graduated scale from which to read the application amount
without having to perform additional calculations. However, pans, plastic buckets,
jars, or anything with a uniform opening and cross-section can be used provided
the liquid collected can be easily transferred to a scaled container for measuring.
For stationary sprinklers, collection containers should be located randomly
throughout the application area at several distances from sprinklers. For traveling
guns, sprinklers should be located along a transect perpendicular to the direction
of pull. Set out collection containers 25 feet apart along the transect on both
sides of the gun cart. You should compute the average application rate for all
nonuniformity of the application. On a windless day, variation between containers
of more than 30 percent is cause for concern. You should contact your irrigation
dealer or technical specialist for assistance.
*Reprinted for Certification Training for Operations of Animal Waste Management Systems Manual

OPERATTON & MADNTENANCE PLAN
Proper lagoon liquid management should be a year-round priority. It is especially
important to manage Ievels so that you do not have problems during extended rainy and
wet periods.
Maximum storage capacity should be available in the lagoon for periods when the
receiving crop is dormant (such as wintertime for bermudagrass) or when there are
extended rainy spells such as the thunderstorm season in the summertime. This means
.that at the first signs of plant growth in the later winter/early spring, irrigation according to
a farm waste management plan should be done whenever the land is dry enough to
receive lagoon liquid. This will make storage space available in the lagoon for future wet
periods. in the late summer/early fall the lagoon should be pumped down to the low
marker (see Figure 2-1) to allow for winter storage. Every effort should be made to
maintain the lagoon close to the minimum liquid level as -long as the weather and waste
udlizztion plan will allow it.
Waiting until the lagoon has reached its maximum storage capacity before starting to
irrigate does not leave room for storing excess water during extended wet periods.
Overflow from the lagoon for any reason except a 25-year, 24-hour storm is a violation of
state law and subject to penalty action.
The routine maintenance of a lagoon involves the following:
Maintenance of a vegetative cover for the dam.
Fescue or common bermudagrass are the most common vegetative
covers. The vegetation should be fertilized each year, if,needed, to
maintain a vigorous stand. The amount of fertilizer applied should be
based on a soils test, but in the event that it is not practical to obtain
a 'soils test each year, the lagoon embankment and surrounding areas
should be fertilized with 800 pounds per acre of 10-10-10, or
ecuivalent.
Brush and trees on the embankment must be controlled. This may be
done by mowing, spraying, grazing, chopping, or a combination of
these practices. This should be done at least once a year and
possibly twice in years that weather conditions are favorable for
heavy vegetative growth.
NOTE: If vegetation is controlled by spraying, the herbicide must not be allowed to enter
the lagoon water. Such chemicals could harm the bacteria in the lagoon that are treating
the waste.
Maintenance insertions of the entire lagoon should be made during the initial iSIling of
the lagoon and at least monthly and after major rainfall and storm events. Items to be
checked should include, as a minimum, the following:
Waste Inlet Pipes, Recycling Pipes, and Overflow Pipes --look for.
I. , separation of joints
2. cracks or breaks
3. accumulation of salts or minerals
4. overall condition of pipes

Lagoon surface —look for:
1. undesirable vegetative growth
2. floating or Iodged debris
Embankment —look for -
I. settlement, cracking, or "juCP
g" holes
2. side slope stability —slumps or bulges
J. wet or damp area on the back slope
4. erosion due to lack of vegetation or as a result of wave action
5. rodent damage
Larger lagoons may be subject to liner damage due to wave action caused by strong
winds. These waves can erode the lagoon sidewalls, thereby weakening the lagoon dam.
A good stand of vegetation will reduce the potential damage caused by wave action. If
wave action causes serious damage to a lagoon sidewall, baffles in the.lagoon may be
used to reduce the wave impacts.
Any of these features could lead to erosion and weakening of the dam: If your lagoon has
any of these features, you should call an appropriate expert familiar with design and
construction of waste lagoons. You may need to provide a temporary -fix if there is a threat
of a waste discharge. However, a permanent solution should be reviewed by the
technical expert. Any digging into a lagoon dam with heavy equipment is a serious
undertaking with .potentially serious consequences and should not be conducted unless
recommended by an appropriate technical expert.
Transfer Pumps —check for proper operation of:
1. recycling pumps
2. irrigation pumps
Check for leaks, loose fittings, and overall pump operation. An unusually loud or grinding
noise, or a large amount of vibration, may indicate that the pump is in need or repair or
replacement -
NOTE: Pumping systems should be inspected and operated frequently enough so that you
are not completely "surprised" by equipment failure. You should perform your -pumping
system maintenance at a time when your lagoon is at its low level. This will allow some
safety time should major repairs be required. Having a nearly full lagoon is not -the time
to think about switching; repairing , or borrowing pumps. Probably, if your lagoon is full,
your neighbor's lagoon is full also. You should consider maintaining an inventory of spare
parts or pumps.
Surface water diversion features are designed to carry all surface
drainage waters (such as rainfall runoff, roof drainage, gutter outlets,
and parldng lot runoff) away from your lagoon and other waste
treatment or storage structures. The only water that should be
coming from your lagoon is that which comes from your flushing
(washing) system pipes and the rainfall that hits the lagoon directly.
You should inspect your diversion system for the following:
1. adequate vegetation
2. diversion capacity
3. ridge berm height

Identified problems should be corrected promptly. It is advisable to inspect your sysn:m
during or immediately following a heavy rain. If technical assistance is needed to
determine proper solutions, consult with appropriate expe—rts.
You should rr--;ord the Ievel of the lagoon -just pzior to when rain is predicted, and then
record the level again 4 to 6 hours after the rain (assumes there is no pumping). This will
give you an idea of how much your lagoon level will rise with a certain rainfall amount
(you must also be recording your rainfall for this to work). Knowing this should help in
ni planng irrigationstorage, applications and rage, • If your lagoon rises excessively, you teen
have an inflow problem from a surfhce water diversion or there may be seepage into the
lagoon from the surrounding land.
Lagoon Operation
Startup:
1. Immediately after construction establish a complete sod cover on bare sod
surfaces to avoid erosion.
2. Fill new lagoon design treatment volume at least half full of water before
waste loading begins, taking care not to erode inning or bank slopes.
3. Drainpipes into the lagoon should have a flexible pine extender on the
end or the pipe to discharge near the bottom of the lagoon during initial
filling or another means of slowing the incoming water to avoid erosion of
the lining.
4. When possible, begin Ioading new Lagoons in the spring to maximize
bacterial establishment (due to warmer weather).
5. It is recommended that a new lagoon be seeded with sludge from a healthy
working swine lagoon in the amount of 0.25 pent of the fuli.lagoon
liquid volume. This seeding should occottrat least two weeks prior to the
addition of wastewater.
6. lriaintain a periodic check on the Lagoon liquid pH. If the pH falls below
7.0, add agricultural lime at the rate of 1 pound per 1000 cubic feet of
lagoon liquid volume until the pH rises above 7.0. Optimum lagoon Liattid
pH is between 7.5 and 8.0.
7. A dark color, lack of bubbling, and excessive odor signals inadequate
biological activity. Consultation with a technical specialist is recommended
if these conditions occur for prolonged periods, especially during the warm
season.
Loading:
The more freouentiy and regularly that wastewater is added to a Lagoon, the bette-the
Lagoon will function. Flush systems that wash waste into the lagoon several times daily are
optimum for treatment. Pit recharge systems, in which one or more buildings are drained
and recharged each day, also work well.

Practice water conservation —minimize building water usage and
spillage from leaking-warerers, broken pipes and washdown through
proper maintenance and water conservation.
Minimize feed wastage and spillage by keeping fevers adjusted. This
will reduce the amount of solids entering the lagoon
Mz=geme=
Maintain lagoon liquid level between the permanent storage level and
the full temporary storage level.
Place visible markers or stakes on the lagoon bank to show the
minimum liquid level and the maximum liquid. lever (Figure 2-1).
Start irrigating at the earliest possible date in the spring based on
nutrient requirements and soil moisture so that'temporary storage
will be maximized for the summer thunderstorm season. Similarly,
irrigate in the laze summer/early fall to provide maximum lagoon
storage for the winter.
The lagoon liquid level should never be close~ than 1 foot to the lowest
point of the darn or embankment.
Do not pump the lagoon liquid level lower that the permanent storagge
level unless you are removing sludge.
Locate float pump intakes approximately IS inches underneath the liquid
surface and as far away from the drainpipe inlets as possible.
Prevent additions of bedding materials, long-stemmed forage orvegetadon,
molded feed, plastic syringes, or other foreign niamrials into the -lagoon -
Frequently remove solids from catch basins at end of confinement houses or -
wherever they are installed.
Maintain strict vegetation, rodent, and varmint control near lagoon edg.
Do not allow trees or large bushes to grow on lagoon dam or embanl=rmt
Remove sludge from the lagoon either when the sludge storage capacity is
full or before it fills 50 percent of the penman=t storage volume.
.. If animal production is to be terminated, the owner is responsible for
obtaining and implementing a closure plan to eliminate the possibility of a.
pollutant discharge.
Sludge Removal:
Rare of lagoon sludge buildup can be reduced 'by:

proper lagoon sing,
mechanical solids =aradon of flushed waste,
gravity settling of flushed waste solids in an appropriately designed basin, or
muun=g feed wastage and spillage.
Lagoon sludge that is removed annually rather than stored long team will:
have more nutrients,
have more odor, and
require more land to properly use the nutrients.
Removal tecbrucues:
Ere a custom applicator.
Mix the sludge and lagoon liquid with a chopper -agitator impeller
pump through large -bore sprinkler irrigation system onto nearby cropland;
and soil incorporate.
Dewater the upper par of lagoon by irrigation onto nearby cropland or
forageland; mix remaining sludge; pump into liquid sludge applicator; haul
and spread onto cropland or forageiand; and soil incorporate.
Dewater the upper part of lagoon by irrigation onto nearby cropland or
fo,azeland; dredge sludge from lagoon with dre or sludge barge; berm
an area beside lagoon to receive the sludge so tna,* liquids can drain back
into lagoon; allow siudge to dewater-; haul and spread with manure mreader
onto cropland or foageiand; and soil incorporate_
Regardless of the method, you must have the sludge material analyzed for waste
constituents jus as you would your lagoon water. The sludge will contain different
nutrient and meml values from the liquid. The application of the sludge to fields will -be
limited by these nutrients as well as any previous waste appiic zzions to that field and crop
requirement Waste application rates will be discussed in detail in Chapter 3.
When removing sludge, you must also pay attention to the liner to prevent damage. Close
attention by the pumper or drag -line operator will ensure that the lagoon liner remains
intact. If you see soil material or the synthetic liner material being disturbed, you should
stop the a=vizy immediately and not resume until you are sure that the sludge can be
removed without liner injury. If the liner is damaged it trust be repaired as soon as
possible.
Sludge remover from the lagoon has a much higher phosphorus and.heavy meta[ content
than liquid. Because of this it should probably be applied to land with low phosphorus
and metal leveis. as indicated by a soil test, and incorporated to reduce the chance of
erosion. Note that if the sludge is applied to fields with very high soil -test phosphares, it:
shouldbe applied only at rates equal to the crop removal of phosphorus. As with other
wastes, always have your lagoon sludge analyzed for its nutrient value.
The application or sludge will increase the amount of odor at the waste application site,
Extra precaution should be used to observe the wind direction and other conditions which
could increase the concern of neighbors.

PossffiIe Causes of Lagoon Failure
Lagoon failures result in the unplanned discharge of wasu water from the structure. Types
of failures include leakage through the bottom or sides, overtopping, and breach of the
dam. Assuming proper design and construction, the owner has the responsibility for
ensuring strucn= safety. Items which may lead to lagoon failures include:
Modification of the lagoon =uct =--an ==PIe is the piac ==t of a pipe
in the dam without proper design and construction. (ConsulLan expert in
lagoon design before placing any pipes in dams_)
Lagoon iigtud Levels --high Ieveis.are. a safety ask.
Failure to inspect and maintain the dam_
Excess surface water flowing into the lagoon_
Liner integrity protect from inlerpipe scouring, damage during sludge
removal, or rupture from lowering lagoon liquid level below groundwater
table.
NOTE: If lagoon water is allowed to overtop the dam, the moving water will soon cause
gullies to form in the dam. On(,,-- this damage starts, it can quickly. cause a large discharge
of wastewater and possible dam failure.

EMERGENCY ACTION PLAN'
PHONE NUMBERS
DIVISION OF WATER QUALITY (DWQ)
EMERGENCY MANAGEMNET SERVICES (EMS)
SOIL AND WATER CONSERVATION DISTRICT (SWCD)
NATURAL RESOURCES CONSERVATION SERVICE (NRCS)
COOPERATIVE EXTERSION SERVICE (CES)
This plan will be implemented in the event. that wastes from your operation are leaking,
overflowing or running off site. You should not wait until wastes reach surface waters
or leave you property to consider that you have a problem. You should make every
effort -to ensure that this does not happen. This plan should be posted in an accessible
location for alf employees at the facility. The following are some action items you should
take.
1. Stop the release of wastes. Depending on the situation, this may ore may not be
possible. Suggested responses to some possible problems are listed belwo.
A. Lagoon overflow -possible solutions are-
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to ;fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
S. Runoff from waste application field -actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that cause the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
D. Leakage from flush systems, houses, solid separators -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed
to flowing leaks -possible action:
a. Dig a small sump or ditch from the embankment to catch all
seepage, put in a submersible pump, and pump back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of --the side walls and lagoon -
bottom as soon as possible.
I'

2. Assess the extent of the spill and note any obvious damages.
a. Did the waste• reach any surface waters?
b. Approximately how much was released and for what duration?
c. Any damage notes, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours call your DWQ regional office; Phone - -. After
hours, emergency number: 919-733-3942. Your phone call should include: your
name, facility number, telephone number, the details of the incident from item 2
above, the exact location of the facility, the location or direction of movement of
the spilt, weather and wind conditions. The corrective measures that -have been
under taken, and the seriousness of the sitution.
b. if spill leaves property or enters surface waters, call local EMS phone number.
c.• Instruct EMS to contact local Helath Department.
d. Contact CEs, phone number - , local SWCD office phone number - -, and local
MRCS office for advice/technical assistance phone number - -.
4. If none of the above works call 911 or the Sheriff's Department and explain you
problem to ihem and ask the person to contact the proper agencies for you.
5. Contact the contractor of your choice to begin repair or problem to minimize off -
site darnage.
a. Connactors Name:
b. Contractors Address
c. Contractors Phone:
6. Contact the technical specialist who certified the lagoon (NRCS, Consulting
Engineer, etc..))
a. Name:
b. Phone: flio :�qq _3-_i )
7. Implement procedures as•advised by DWQ and technical assistance agencies to
rectify the damage, repair the system, and reassess the waste managment plan to
keep problems with release of wastes from happening again.
2

INSECT CONTROL CHECKLIST FOR ANIMAL OPERATIONS
Source Cause BMP's to Minimize Odor Site Specific Practices
(Liquid Systems)
Flush Gutters Accumulation of solids ( Rush syst—.. is designed and operated
sufficiently to remove accumulated
�riids from gutters as designed.
( T Remove bridging of accumulated solids at
discharge
Lagoons and Pits Gusted Solids ( =ain lagoons, settling basins and
pits where pest breeding is apparent to
minimize the crusting of solids to a depth
of no more than 6-8 inches over more than
30% of surface.
Excessive Vegetative _ Decaying vegetation Maintain vegetative control along banks of
Growth lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along water's edge on impoundment's perimeter.
(Dry Systems)
Feeders rood Spillage ( ) Design, operate and maintain feed systems (e.g-
bunkers and troughs) to minimize the accumulation
of decaying wastage.
(} Clean up spillage on a routine basis (a.g. 7-10 day
interval during summer. 1 S-30 day interval during wittoer).
Feed Storage Accumulations of feed residues () Reduce moisture accumulation within and around
immediate perimeter of feed storage areas by
insuring drainage away from site and/or providing
adequate containment ie.g., covered bin for
brewer's grain and similar high moisture grain
products).
() Inspect for and remove or break up accumulated
solids in filter strips around feed storage as needed.
;nimal Holding Areas Accumulations of animal wastes O Eliminate low area that trap moisture along fences
and food wastage and other locations wnere west@ accumulates and
and disturbance by animals is minimal,
() Maintain fence rows and filter strips around animal
holding areas to minirrrize accumulations of westm
G.e. inspect for and remove or break up accumulated
solids as neededl.
11C-November 11. 1996

pry Manure Handling Accumulations of animal wastes l } Remove spillage an a routine basis le.g. 7.10 day
Systems interval during summer, 1 S-30 days intervei during
winter} where manure is loaded for land appicutien
or disposal.
(} Provide for adequate drainage around manure etodtpaaa_
(} Irmpecr for and remove or break up eeoumulated wastes
InSmlter stripes around stodtpilas and mamm hwdanQ
areas as needed.
The issues checked ( ) pertain to this operation. The landownerfintegrarcr agrees to*use sound judgmen; in.applying
insect control measures as practical.
I certify the aforemerrdoned insect con tro( Best Managemerlr Practices have been reviewed with me.
downer Signature)
For more information centsithe Cooperative Extension Service, Department of Entomology. Box 7613,.North Carolina Stem University, Raisigh. NC
2769S-7613.
AMIC—November 11. 1996

SWINE FARM WASTE MANAGEMENT ODOR CONTROL CHECKLIST
'source Cause SMP's to Minimize Odor Site Specific Practices
Farmstead Swine production V etanve or wooded buffers;
( ecommended best management
Good judgmenr and common sense
surfaces Dirty manure -covered animals (.Yo;v floors
Floor surfaces Wet manure -covered floors (`j Slatted floors;
( erers located over slotted floors;
(>ers at high and of solid floors;
(} crape manure buildup from floont;
( ) Underfloor ventilation for drying
Manure eallection pits Urine ( requent manure removal by flush.
pit
reeharge.or scrape
_ Parital micorbial decomposidan O Underfloor ventilation
Ventilation exhaust farts Volatile gases; { Fart maintenance;
Dust ( ) Efficient air movement
Indoor surfaces Dust (kWashdown between groups of animals
( ) Feed additives;
() Feeder covers;
{ } Feed delivery downspout extenders to
feeder covers
Flush tanks Agitation of recycled lagoon () Flush tank covers
liquid whiles tanks are filling {) Extend fill lines to near bottom of
tanks with anti -siphon vents
lush alleys Agitation during wastewater [) Undarfloor flush with underfloor
conveyanance ventilation
Pit recharge points Agitation of recycled lagoon {) Extand reenard lines to near bortom.of
liquid while pits are fi7fing pits with anti -siphon vents
Lift stations Agitation during sump tank filling ( ) Sump tank covers
and drawdown
Outside drain causation Agitation during wastewater () Box covers
or junction boxes conveyanca .
°nd of drainpipes at lagoon Agitation during wastewater { } Extend discharge point of pipes
undemeatri lagoon (iouid level
_agoon surfaces Volatile gas emissions (;Proper lagoon liquid capacity
Biological mixing (4-torrect lagoon startup procedures
Agitation (l Minimum surface area -to -volume ratio
J),, irtirnum agitation when pumping
(} Mechanical aeration
() Proven biological additives
rigation sprinkler nozzles Hign pressure agitation (JAfrigate on dry'days with firde or no wind
World draft ( !v{irrmum recommended ooeratian pressure
(.j'Pvmp intake near lagoon (icuid surface
( ) Pump from second-srage lagoon
AOC—November 11. 7996

Storage tank or.basin Partial microbial decomposition {) Botrorrl or midlevel loading
surface Mixing while filling () Tank covers
Agitation when emptying (! Basin surface meta of solids
() Proven biological additives or oxidants
Sorting basin surface Partial nvcabiai decomposition ( ) Extend drainpipe outlets underneath liquid
hQxdng while filling level
Agitation when emptying (),Remove settled solids regularly
Manure, slurry or sludge Agitation when spreading {) Soil iniection of slurry/sludges
spreader outlets Volatile pas emissions (! Wash residual manure from spreader after use
() Proven biological edditivas or oxidants
Uncovered manure, slurry Volatile gas emissions wMe drying O Soil infection of slurry/sludges
or sludge an field surfaces {) Soil incorporation within 4a hours
() Spread in thin uniform layers for rapid drying
(! Proven biological additives or oxidants
Dead animals -
Carcass decomposition
( roper diap"rion of carcasses
Dead animal disposal
Carcass decomposition
() Complete covering of carcasses in burial pits
pits
{) Proper location/construction of disposal pits
incinerators
Incomplete combustion
() Secondary stack burners
Standing water around
Improper drainage
(# drada and landscape such that water drains
facilities
Microbial decomposition of
away from facilities
organic matter
Manure tracked onto public
Poorly maintained access roads
{ Farm access rood maintenance
roads from farm access
Additional Information: Available From:
Swine Manure Management: 0200 RuieBMP Packet
NCSU-CourttyExtension Canter
Swine Production Farm Potential Odor Sources and Remedies, ESAE Fact Sheet
NCSU-8AE
S wine Production Fatuity Manure Management. Pit Recharge —Lagoon 'treatment; ESAE 123-88
NCSU-W
Swine Production Facility Mamrs Management: Underfloor Huse—(.egoon Treatment; ESAE 179-88
NCSt�-BAE
_agoon Desig and Management for Livestock Manure Treatment and Storage; ESAE 103-83
NCSU-SAE
calibration of Manure and Wastewater Application Equipment ESAE Fact Sheet
NCSU-SAE
=ontrolling Odors from Swine Buildings: PIN-33
NCSU-Swine Extension
nvironmental Assurane Program: NPPC Manual
NC Park Produces Assoc
options for Managing Odor, a reparr from the Swine Odor Task Force
NCSU Agri C.armnunicirdorm
Juisence Cancems in Anirnal Manure Management: Odors and Flies; PRO107. I99S Conference Proceedings Rarida Cooperative Extension
'he issues checked ( ) pertain to this operation. The landownerTrrregrator agrees to use sound judgment in applying
dor control measures as practical.
certify the aforemerrdoned odor control Best Managment Practices have been reviewed with me.
(Landowner Signature)
IOC —November 1 1 , 1996

MORTALITY MANAGEMENT METHODS
(check which method(s) are being implemented)
( ) Burial three feet beneath the surface of the ground within 24 hours
after Knowledge of -the death. The burial be ar least 300 feet from
any flowing steam or public body of water.
( %/� / Rendering at a rendering plant licensed under G. S. 106-168.7
{ ) Complete incineration
{ j In the case of dead poultry only, placing in a disposal pit of a size and
design approved by the Department of Agriculture.
( j Any method which in the professional opinion of the State
Veterinarian would make possible the salvage of part of a dead
animal's value without endangering human or animal health. (Written
approval of the State Veterinarian must be attadhed)

k, located on Bear Island, has
e most beautiful and unspoiled
,rf"the Atlantic -Coast. It is ac-
inly by private boat or free
ferry. Surf swimming 'is an ex -
ere, as is the excellent channel
shing. o4
W UJa F=
Ca
W 0
01
UN LM
0 IL
UN - LM
OU"rr 80,V MUFAOM
tM
A
LLH Irk
.5
tW
—A
UU
F .004
♦
LUI
IMF
e
q
ta L30
P1
-AU
LLU
116
LLn
LIN 'D
U"; I.M
LLU
LM
Iry
U32
LZU
au
:5 Beach State Park
IM.
t.L.
UU
5 ttLz
most beautiful and un-
Lin
Oft
�s on the Atlantic Coast is
Dun 'K, M,
kku
'W
each State Park, located
0
This beautiful, unspoiled
essible by free passenger
boat.
iing., picknicking and a
MU
available at this park's
<(
IM
aced 4.5 miles west of
State Road 7511. Ex-
I/
and serf fishing for blue-
ounder, speckled trout,
C'

No-s sheer :7
n
m
a
L
C
O
MM.
SOIL SURV

, ,•, �:�' /
�'�r f• �� M,%. ♦ •.:' .•a, "'•l !fit � Ya,...;+�M�tii[.•�' :•i- ••l t:�k �Y::•��•,, :.. .• •.' .C�' i
••' y'• •• .i y � F,L X
S'ri1 7-ft �k c �,.`r. a. :'.�,• � • s.�} :.i `.' �;'.r ti � �,!, r►tyyr: !.. •n. 4��'�.a..• _ r• � R'
•�,r _ ,' •' 'Ya .Vtii f'' Y. i(�, a '-. -+ �� ti . �..r.tiL!� 'j'S'N�!``�i' 1 '... • r �..i� �• , �' V
s+4� a.. p �� .y•*� r- •��N►=;=-.i :•.� . �i; . �•,y4�fSI ,.r i x f-.`� -,• -
•�♦ t- •r`_ \i ` r � ��Z �' r'.'�r' • ry �•� i{�„':1J} .� : :».!` � '� »;�` L'f`. J `r `-. :h+i! �� ;i�r:� .;:.
r•:
a*�..yr a ij I,.�t�ll �•�` ,..y_.S,l ,`��.. +a t _ �'• .y•_:..�rs"���:;N':��.
w ` f•• k 'i� ». Yr ,..4 •��a ate. fr/ ff..- •-`Z Y�'. a� Y,ti1.}'w
•r" F i•:•. R]��. •� _ .y�' �,ir�Y,• ::ft.s ..- a� ss -.' "w i r'� . a^-.•• .�.',y'S Li •�rl�".
�r Ali 1 •[ . . t .. � ir. �. a' -. f- _ •�: �_ •''- ��rr '•'r s,�'.�'r r,�-.•':.. •:M
• 1 tip:' .. a : - -.�� • f4 � ��i ` :f� -
�Cir,: + ,�y jj�+rya'-j• r 't.•:!•."ct'C• t,. ''. :T- �;�.?.. r.y,.
�riN•" 'a• ,i .. J:'��e �:a•',�.. .^ - �1•tii� V• to - '1`�1'
�� ! � ..: •' , + •+ � ' '� l�'ry `�� ' !.ram+'
titi "':.M �ir",�ty �'i+• - - »fir`± .,o i[`7�`.,y f
} �+ i. fig. *;�: � .' � �'" � •?. a� ..- = •, ._•./.'r.
•'M"j•'ti-�5 e !1. .f ti„yj,l• .: _. ,•. fi'fi � �•'L :�,"y �Cr_i:� ���• .. •.?.Z' �` � '
,,�!�, �''� ";- : . •a �� i. 1.-j° J -��"� it - y.• }i ' i . sJ :a
Ape-
. •:r. • x
�r�ri-�' ,. �+` ti`•. ':� -��� -A •�j%'i%Y.�•`4'��:' �'s,''' •�1.•f,•" s.. ���r•"•a`•
•. fZl " • yam`. • � �- � '�lr• '4•�� -;M ._'•'+_�~•�.� r'a'�''" •,-�� � t �Y'
• Is 3 �, ,(f.':.i f4-• I:
�� Y�,� i �, i:•. �r:�.0'{ y~`'��+��c• ••_ ,.� :.► :r'r!r.'��..}�-• .��t,.t��i'r'��•''.':•J'� - ��-_:-.. �.My�ayF
� : •'�l'-r �`�: �`�" �(�_„'l�(_'•': •. x•., . i --?./a,�►;=y.'u`.i ��5(� .�`,4..1. �i '��� ', • ,�,- -ate.+ y �s• R
, ,5 •a `_:��.}�-, •� Iti���r. 4-��.��•',`_ _' fit,-���'b:• w�st•� 2^("r';:.� =y„ `•;�y.�� •� .:�•j,�!.'!4••.f ��-=.�'~. __ ,�'_. L���•`_�iyf.[g -
I � :��+,L�, 1 * y+•�• r._ '��=�:.�we\; �_^"R• �,s 11a''yv^�.• - _ "-s_ � �"�.wy
.s t: : i.-e �'�:, • "'�;'S! �• �"`� ae + �„d r'l`�''*i- . ::ti p>y
. L.. .. _y.. � - • yr►"..�� � `;w"w• ._ 1
i- r;atry y `� M1'-•} % r ��+,,�,J_"� a• �}�Yi•� aell
; .�•• .l.a�]((py
:-r," , .!..\ •t •Jtt l-+'' '�:/rr '�Y� ,sy� .A���"rZi1�/ft r.Vr-
`ta 7 r-�S ' .~ •; '�{yA�P� _. ::I �j ,~7v .y.ar'`'•• :•y�.
«1! ta ` rr •fit ��a•`::2• ' _4' +� e�
� i' , r • i
r l� .r�1•,,� �t:- ' .'�f" • 'yam �!. � •. *'G.w .a l t .fit a i♦ '��
• .a : f': . •+ ., .... - -j•a� �r • . • Y'��+. �\ .fit . �q,� 1 �'�•
-..La["�• -2 iL• `r, y,•w v►• irl ..3 I!tt ^ 1 %,7► .7; •• - ,Fib•
+~: ,"dW
`•`' �.: 1',+••• �� .'� •"fix `:i4' • a �. T` t' v" of b'.aC . ''y'^ .�i
AL
,,rf►�., s wyyr
._ •r.� r �. .li•S'.F. {i�' t3- •s•. - �Iw. . i _`• s• .
.:,• �rl - . ,'tea. _ n_ :�','`'r��'.�•�: �• �. � t�, � ���
15�• •i1J'�::.�f • ra• l.r�.wa
AN p
'a.•'F+,:• _ .. � � . `^ "� .kL.,. •'a law % "-`• ;�• � r, ;�
it fy 1 �. y + � . . • �' •' • '.� a•' w1.:

M t11 RP HY
FAMILY FARMS
October 10, 1995
Mr. Harry Tyson
District Conservationist
USDA - Natural Resource Conservation Service
604 College Street
Jacksonville, NC 28540
RE: Morris Brinson Farm - 2448 Feeder to Finish
Dear Mr. Tyson:
RECEIVED
WATER QUALITY SECTION
Off 1 41996
Non -discharge Permitting
Enclosed for your review is the completed Animal Waste Management PIan for the
above referenced swine farm. Specific items included in this package are as follows:
- Location Map
- ASCS Tract Map
- Soils Investigation Report
- Lagoon Design Spreadsheet
- Operation & Maintenance Plan for Lagoon
- Construction Specifications for Lagoon
- Site Seeding Requirements
- Earthwork Calculations -
- Site PIan with Construction Details
It is my understanding that the Waste Utilization Plan for this farm will be developed
for the grower by your office.
PIease contact me at (910) 289-21.11, ext. 4629 if you have any questions concerning
this package.
Post Office Box 759, Rose Hill, North Carolina 28458, [phone], FAX [phone]

i
Sincerely,
M. Kevin Weston
Engineering Technician
MhW.tbh
Enclosures
cc: File
Moms Brinson, (complete package)
George Learning, Murphy. Family Farms Construction Dept. (site plan only)
Dave Roland, Murphy Family Farms Transportation Dept. (site plan
only)
N

the most beautiful and unspoiled
on the Atlantic Coast. It is ac-
only by " private' boat or free
�r ferry. Surf swimmingIs an ex -
here, as is. the excellent channel
fishing.
4Ltf • 11q
.1�
1N
.31
n
'T To row" Wpap K1."0
,e 1%,1
nocks Boach State Park
- the most beautiful and un
-:achas on the Atlantic Coast i;
-s Beach State Park, locate(
land. This beautiful, unspoilec
y accessible by free passenger
ivate boat.
•1imming, picknicking and a
are availableat this park's
located 4.5 miles west of
0. 'Dff State Road 1511. Ex-
nel and surf fishing for blue.
:er. floundlbr, speckled trout,
C,
t
S
o
'/
/
If
,
•5
1
�
ybb
In11111�.
I� ref
h-..ly....
Ug
0.1
'lu
uu
•
., �.
tM
,
,
1 '1ti'Yti►ii 1nl
�,
.: ,e .•wl[j ' R uN
{F -
o...
` Vwr
.
Au I/K
If �
1..1
.UNi
I7
rbM.
1
C
!I
toIMi
Un
J '
, ..Illt •.,
% •::
uu 111E
U v11 ylV4
� � ,
"" •, �. tw tut an .. � ,w
.ej1,'a,.,•
, ♦ � 111r
u11 4' uu h....+ ..��
� ^
1 ,.—.r, �Vr
1 r „1`
�
LM
�ti
4
10
31
u11
tus
V It11
�► 1111
JIM N
W1
..
\UJI
1,
111t
,I.
Itu LW
O A16-
,
1111
'ir1
.►
,
IIN
•\G
1i�.1
1j'
1J
IM
C
�
111•
IMI
, .
IAM
tut
lu
uu

NO
jr
Mo
IS

LAGOON SITE
SOILS INVESTIGATION,
PROJECT:
�Iot�,s
/'2�n�f�n�
COUNTY: p�1Gvd
FIELD INVESTIGATION BY: le P
OATS: F/'c
SI_TE.SKETCH
J
I
I
70
-41-
z
.
'BORING
?EP,TH�
BORING NUMBER AND PROFILE
�30A"LE=r
-':Q%_7''';''z�
*+{�i�4
' %
r�.*.�o
o =�. t �
n,•,o 3 "�
D= /•s I f� 3.5 r�r
f;� /� •
' 'o? `. A r C tAr
-s 7'
S.o.,n CL�r �I nt
!,S'�.5� n.� cnr CGR
irXi.9ri
7. J /
CLwY
7 ' 1 s I r1 0 .+ Cci+f icwxeLrf
lG
Ar r NO le
It-wr
!•4 - �f,s'
MY CtA:
1
,.(o '..'-
-
r n�o y.0
-
.moo w "4 to at f
1'S•
),4,-W ,A
Y C Pti C, y
C-
�. !D1
r
ca c r
f 'f
Lr.A
%/D
,,,,, «1 CLAr ,rC*f
4 - rkr�
'SAao .. eLA7 /OL4
9% r 5
iArofr-* G
,o= AS
eLAY c. fArr (o,,ce.rJ
I
-L iw•M.Ab �
9�
�
I
`j
BRING / SAMPLING METHOD:q
SIGNATURE:

Operator:BRINSON
Count; : =_=============DNSL0W
Date: 09/29/95
Dist.to nearest residence (other than owner):
1500 ft.
sows (farrow to finish): __ 1".
sows (farrow to feeder): eder):--- _— _----===—=i
head (finishing only): ====---___= --___-
2448
sows(far rowtowean):===—_ __-_�___----===r•
head (wean to feeder):===--
Ave. Live Weight for other operation s(lbs.)=�
Storage volume for sludge accum. (cu. ft):=
Treatment Volume (min. 1 cu. ft'_lib_)====== r
1.0
25Year — 24 Hour Rainfall (in.)===___—_====r•
8.0
Rainfall in excecc of evaporation (h_)=====r
7.0
Drainage area of buildings $ lots (sq. ft.)=�•
Volume of wash water (gaiions/day)====_--===r•
Temporary storage period (days)========----=:
180
Reebmrd (ft.):� _____-_-----------------_
1.0
Side slopes (inside lagoon):=====--==
3.0 : 1
Inside top length (ft):- __---_--------=—=—=x•
240.0
Insidetop width (ft):----------------___---_ .
320.0
Top of dike elevation (ft.):-=__— - ________—_.
93.2
Bottom of lagoon elevation (ft):===_—___—__.
83.2
Seasonal nigh water iable(SHWT) elev.(ft):=>
86.3
Total required volume:===== ---___ _= 507185 cu. ft.
i "TOTAL VOL O.K.**
Actual design volume:===--= --____= 536868 cu. ft.
105.85%
Stop pumping el.(> or = to 86.3 ft.SHWT)>
89.3
(> or = to 89.2 ft.Min.)
Required minimum treatment volume: 330480 cu. ft.�
**TRW. VOL O.K**
Volume at stop pumping elevation: 337321 cu. ft.
102.07%
Startpumping elev.:=----------------------
91.3
Volume at start pumping elevation: 472062 cu. ft.
**STORM STAR. O.K.**
Actual volurne less 25yr-24hr ram: 485568 cry. ft.
1 Q2.88%
NOTE: Verify that Lamp. storage is adequate:
Req. volume to be pumped:== ==> 125505 cu. ft.
**TEMP. VOL D.K.**
Actual volume to be pumped:==> 134742 cu. ft.
107.3fi/8

rrator^:M. BRINSON County: ONSLOW
stance to nearest residence (other than owner):
AVERAGE LIVE WEIGHT (ALW)
Date: 09/29/95
1500.0 feet
0
sows
(farrow to
finish)
x 1417
lbs.
— 0
lbs
0
sows
(farrow to
feeder)
x 522
lbs.
— 0
lbs
2448
head
(finishing
only)
x 135
lbs.
= 330480
lbs
0
sows
(farrow to
wean)
x, 433
lbs.
= 0
lbs
head
(wean to feeder)
x 30
lbs.
= 0
lbs
Describe other •
0
Total Average Live Weight = 330480 lbs
MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 330460 lbs. ALW x Treatment Volume(CF)/lb. ALW
Treatment Volume(CF)/lb. ALW = 1 CF/lb. ALW
Volume = 330480 cubic feet
STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0.0 cubic feet
TOTAL DESIGNED VOLUME
Inside top length (feet)---------------------- 240.0
Inside t o p width ( feet) ----------------------- 320. 0
T o p of dike elevation ( feet) ------------------ 93.2
Bottom of lagoon elevation (feet)------------- 83.2
Freeboard (feet)----------------------------- 1.0
Side slopes (inside lagoon)------------------ 3.0 : 1
Total design volume using prismoidai formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH
3.0 3.0 3.0 3.0 234.0 314.0 9.0
AREA OF TOP
LENGTH * WIDTH =
234.0 314.0
AREA OF BOTTOM
LENGTH * WIDTH =
180.0 260.0
73476 (AREA OF TOP)
46600 (AREA OF BOTTOM)
AREA OF MIDSECTION
LENGTH * WIDTH * 4
207.0 287.0 237636 ( AREA OF 'MIDSECTION * .4 )
CU. FT. = [AREA TOP + (4*AREA MIDSECTION) + AREA BOTTOM] * DEPTH/6
73476.0 237636.0 46800. 0 1.5
Total Designed Volume Available = 536868 CU. FT.

TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
240.0 320.0 76800.0 square feet
Buildings (roof and lot water)
0..0 square feet Describe this area.
TOTAL DA 76800.0 square feet
Design temporary storage period to be 180 days.
Volume of waste produced
Feces & urine production in gal. /day per 135 lb. ALW 1.37
Volume = 330480 lbs. ALW/1.:5 lbs. ALW * 1.37 gal/day 180 days
Volume = 603677 gals. or 80705.5 cubic feet
Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in SA.
Volume = 0.0 gallons/day * 180 days storage/7.48 gallons
per CF
Volume = 0.0 cubic feet
Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall 7.0 inches
Volume = 7.0 in * DA / 12 inches per foot
Volume = 44800.0 cubic feet
0

e
Volume of 25 year — 24 hour storm
Volume = 8.0 inches / 12 inches per foot * DA
Volume = 51200.0 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A.
80705
cubic
feet
5B.
0
cubic
feet
5C.
44800
cubic
feet
51D.
51200
cubic
feet
TOTAL 176705 cubic feet
SUMMARY
Temporary storage period________________=___>
180
days
Rainfall in excess of evaporation=====____=_>
7.0
inches
25 year, — 24 hour rainfall-==_______________)
8.0
inches
1.0
feet
Side
3.0
. 1
Inside top 1 en gth___________________________>
240.0
feet
Inside top width____________________________)
320.0
feet
Top of dike elevation _______________________>
93.2
feet
Bottom of lagoon elevation====______________>
83.2
feet
Total required volume====___________________>
507185
cu. ft.
Actual design
536868
cu. ft.
Seasonal high watertable elevation (SHWT)===>
86.3
feet
Stop pumping elev.=—==_=—==—W_______________>
89.3
feet
Must be > or = to the SHWT elev.==== _____>
86.3
feet
Must be > or = to min. req. treatment el.=>
69.2
feet
Required minimum treatment volume=====_=____>
330480
cu. ft.
Volume at stop pumping elevation=====_______>
337321
cu. ft.
Start pumping e i e v .=—_—_--------------------=>
91.3
feet
Must be at bottom of freeboard & 25 yr. rainfall
Actual volume less 25 yr. — 24 hr. rainfall==>
485668
cu. ft.
Volume at start pumping elevation=====______>
472062
cu. ft.
Required volume to be pumped=_______________>
125505
cu. ft.
Actual volume planned to be pumped=====_____>
134742
cu. ft.
Min. thickness of soil liner when required==>
1.5
feet
DESIGNED BY: �P�11��, APPROVED BY:
�.
DATE: DATE:
c•
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
COMMENTS:

This lggaon is designed fur waste treatment (permanent storage) and
180 days of temporary storage. The time required for the planned
fluid level (permanent and temporary storage) to be reached may vary
dues to site conditions, weather, flushing operations, and the amount
of fresh water added to the system.
The designed temporary storage consists of 180 clays storage for:
(1) wci!.;te f"Fen canimala and (2) excess rainfall after evaporation. Also
included is storage for the 25 year -- 24 hour storm f oT the location.
Tits:_ vulumu of waste :Au"a':2'rwated '! : a. m 0 g:a'ren n;,lmbe'i of animals will b
fai•: ly constant throighout the eat and from year to year, but excess
rainfall will vary from year to year. Tali': 25 year rainfall will not
be a factor to consider iii an annual pLtmping cycle, but this storage
volume must always Le tovai! .•.€f1l•
h maximum Llevai-•io;. is Jeterminwd in e:1a.:h 6a.:•ziJf1 to begin
€'_i.ifisi.'.i"g ane this is usually Ui c ,tinu inzevt u7 h.ipy:s; i•i UI1t
bui .d lnr ,.$) . _ F th& wallet pipe is out A,._ ,rc:., l _L ... 01a alL vwi.•ian tt.
0440)
Pumping can he stas•i'v_e aT :hopped at any time Leti+:eL" these 'a.wc.
ie',,atiLM fa:.. =pe,..a _Vg .-._ .•Ui l_is_n 0I ____ __ . til..iy PEOit 0! -Uw11 as
we ..'L',1:_. ,'y . & E, CrOP, •amd ...j;:,.EiRiu"t iP U: �c 0, , .. j WST _a 41_.:C V11;
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set$
center pivot, guns, and traveling gun irrigation. Care should be
taken. when applying waste to prevent damage to craps.
The following items are to be carried out;
1. It is'strongly recommended that the treatment lagoon be pre --
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times. When rrecharging is complete,
flush buildings with recycled lagoon liquid. Fresh water should not
be used for flushing after initial filling.
2. The attached waste utilization plan shall le fcll,owed. This
plan recommends sampling and testing of waste (see attachment)
before land application.
3. Begin temporary storage pump -out of the lagoon when fluid level
reaches the elevation 91.4 as marked by permanent marker. Stop pump --
out when the fluid level reaches elevation £9.4 . This temporary
storage, loss 23 y r-- 24 h'r• storm, ca"tains .125503 cubic Feet or
938781 gallons.

4'. 7k,io maximum amount to apply pep irrigation is
one (1) inch and they recommended maximum application rate is 0.3
inch per hcuT . Refar to the waste utilization plan for 'Further details.
_ Keep vegetation on the embankment and areas adjacent to the
ti
Zr1,(.7i:ir iiGwe d annually. V4_gelation KgM he
I.l:'Tti.liz('d as 1tiC'i?(.ed
to maintain ,a vigorous a3La�a':ili.
i. Rfepni'i' a Y; e:'i'oda6 areas oe areas damaged b/ rodents and
2stablish in vegetation.
r'.. All suvTocs P na -_. .ii liyre'it_.d from .."gouty .,_l rLa_._i_
t.. Keep a minimum of CJ feet of u -ass vea'l']L. V.cli.;. 2 bu : fer around
a ..._ .. 4 1 1 !... _. _ .. +...- : i i _. _. . j .... _ .. o ' +:- _ .ti is .... 11
iiC:7i: s:ii; cijip1...a1li Oj:}eli L::.4c.._.E>. ..:q nat i-0:ilf. :+:it+.1'•i 200 r`:iu z'i 4
"each ;.}uili.'. + + -.. .t.4V.l P..:. _-.. ..

I
A N
';3Prc1F'1c;)'r1f)NS 1-.'01' CONSTRUCTION OF WASTE TREATMCNT LAGOOms
'FOU14DATION, PREP(.)RATTON:
Thu, of .11-he �,Ftd bUildil')U Pad SlIzAll be
L I f J '1 17 V .. i� c) C, t 1'j 'r '! S' I*'-
C1i5j)L)5jtdo-,-, will LL) e AS a d e u%' ctii dc:.'bris. Tj-,E 'L-op'suil from
;,m, p,id are&., should F-t-D-f- uso Gil
aiof i thO Of L-;iL,
c) r f i �1 t
'4 1 'i f J.L -.41 i V% I i I'
71
I VlT
61
0 J
1, L
Th i K. rn e c h e I S E C, T I ON 0:-- TH 1 S SP Er' I F 4 . 1-1 1
S; t.1 I I R C! LIL S is-i he 111 U TE' n) pe 0 5 11) .01 i :k 1 s 1 U h) t! C' :.j i-k 7'
e X c a v at inn s'. C. on. s t c 1; i i.� c. F -F I 11 h e 11t, -h
s e I e m e n t' Dikes ove-.:, 1.5 f-=et in heiiuht- a'. --id
c a c: a. I; c) I C . . - - I
C, -!- I
. E f"�' v -"' f
Darri Safety Law. Till: h e h t is def i-ned its: th E- U-' 'i '2 v c' -n li: e 1 e v 't 0
f-rc;'n the coristrLk(:ted 1-1- u h -L L:..f ths-: k. C.,
P'reC.W,p.r. e V e,1yL e X C L� _
t-iQ1-i5 Shall be tar'.,.en ClUT'il-Ig C0l-1St-f'LkCti01) 'A'C- C
erosic-n and sedimeritaticin.
1 . r_— x '�
LINER; THE MINIMUM REQU1rr1','ED "I"HICK.'4ESS SHALL. BE J L.
REZ-1"JI-ED D G C 1 L
L r. NOTE: INERS (PARTIAL OR FULL) � I T 1-1. E ',) T F
I1qVE'JT'J';r.TI0'N SO Ii-:"J1.7,,^,TES OR Ll T A P
t .— , . 1 .7 . '. i. . - * L- .6
ENCOUNTE R E D D4JR I N G C O'X GTF'%'UC T I ON . A TYP'I CAL CRO S'S SECT 1 C 1-1 ',"-F L 1.14'r—_ R'
T.3 INCLI..)DED' Ir' THE r
141--EN LINE17%'S PIKE BY THE ZDILS RET:CRT.
When areas of junsuj -ita' le ma'arial a,rL- e)- C ' - fL .
L) 1 0 t.� F1-'' e C., d , t h e y w -- 11 be over_
eXCaVate(' beloW f jJ-1j,
j iJ-1 YLf-ado to the spacified depth as mea:Lcred
h-T�-'rperpendiCUILaT o ht- nisgi-ade. e f0LtfLLE%t:!D)ShF% be bacr.fi I le d
e s i f e. d t cz u .1 C j
RE F E R 10 1 -1 rl C I L S 1 1,! V7 G� T I 'Q A T 1 7:4 F 7 .A
L
C 0 N 3 1 D ;7 FZ:1 T 'I.l7i'ir.

Ci6i,I. li'li52i' Ill ii:L!'r' l.cel shall come Crom an approved borrow area. The
minimum wata7 content of the liner material shall be optimum moisture
4.:eJllLent 7Jhi.l:`. rulatos to that moisture contanQ when the sail is kl;r:cSded
in the hand it wi.l,l form a ball which does not readily separate. Water
` shall l I.14: added to borrow as necessary to insure proper moisture lontent
du;:ing placol.ent of the liner. The moisture content of the liner 01
material al. t.ihal4 not he arse Wan e3ptu'LrIIum watli''I :Ulltunt rtl.l',`ing placement.
The :ii:e:ll,rie.n :eatF.:'I'' L:1}'a'tent relates to We ._oil matE7Tial being ou wet:
fa, ... it:i. w... aye of !aiding uquipmanL and p:'apk_r compaction. Proper
nawpowticn cf the liner i'rI':ludasi plaL:e:weIit in I inch .lifts`' anG
..:5.Q _..'f:ya t" at aIGcFnt Jo Jti•?l`i=i','l,t of {;A4. mc+.X,t.C.lum ASTM
B 9 Day I' J
.4 wnt: Pr, 0 . linuo material. r•.P'...1. bw.wth 04 ,:ee'I d, Wo i.;1 ..,ions ZQ
t y,no!! G'i :_ _........' J. -�' '.i I. ! _. ,-'! :.� L:!� ...:� ' i.: ,l w k tit':. " ..._ .... ... :_ Ca I . '! ._ i- .i. t:l';.:.'!k I4._ i .. a: c f t h (: next
.._ ,..i .
.,..J. r wn ._ i. = s , .. _. , } i a a...: n k111Q, ..... L _. I.. .. .. .� .,.. h C ,.. ti:.: _: t_' n. _ - 1 a. • , _ 'i .
.. . .
Alternativ&y .0 sail ...LnZ'.'. L, y. _;'n tl1u - l _. 1 . .1 a ,..,
included with this Construction Specification.
CUTOFF TRENCH-
-
A cutoff trench 9shal.l be ccnet'ruci:ed ul :ier •ljlo _:ii:bsli•ikf;;e'I't c5v ea Ken
shown an a typical c're]'ss section in the piano. T hE rinal iep t:"I Jj -the
cutoff trench' shall be determined by observation of the 'foondar'ioi-;
materials.
VEGETATION:
All exposed embankment and other baoe areas shall le seeded
to the planned tY PQ Of Veget 1ti*n an Soon aS POSSible S yta I i(:;'.,_trUCL—,
tion aeccordin2 to the seeding sp cif ].C:'aci:an=. ; oi;_ oil .ihuuid Le placer,'
an areas of the dike and pad to be a.l,=ade . T(_!1`purcary seeding .:''i iiii_IW-i
shall be used if the 'recC)Ilil',ended pe'i`i:Jtitnent •✓:gr'"r;ation is out QT season
dates for 8i''L'ding. r°e'I mazn(:'n! vegetation whooll be ✓':s't_tbl i.:hI•ed as `..soon
as possible during the next period of approved seyhin1 dates.
REMOVAL OF EXISTING I INN TILE DRAINS
--------------------------------
v:hon tile drains
aye ei'iGounteve
d, the 1,0_ will 111ir..IJ1LU.;
ofL fi;;r_
a.i
t 1:?'.- •��3iii:
1 .1
the
!':.. Lii.it:i.i I... tooK
...L .r.: or Lh, d ].ku . I T .y+ L. l..i.i'-
t'rench
shall be
baackf illed and
compacted wi Uh good material tsui h a.�
SC, C:_y
or CH.

SEEDING SPECIRCATIONS
----------------------
AFEA TO BE SEEDED: 3.5 ACRES
USE THE SEED MI.XTU RE INDICATED AS FOLLOWS:
210.0 LBS. FESCUE GRASS AT 60 LBS.;-'ACRE
(BEST SUITED ON CLAYEY OR I<VET SOIL CONDITIONS)
SEEDING DATES: SEPTEMBER I TO NOVEMBER;30
FEBRUARY 1 TO MARCH 30
105.0 LBS. RYE GFWN AT30 LBS. ACRE (NURSERY FOR FESCUE)
0.0 LBS.'PENSA-COLA' BAHIA GRASS r T 60 LBS :/ACRE
(SEE FOOTNOTE NO. 1)
SEEDING DATES: MARCH 15 TO JUNE 115
lC��ljT�f''.,Cnn ha�nT rrY'�fl �,rtn�r'rrTlr�,+iC,\
�•J . �. ...I • L � . ail ,..:•1 . ti,7 •1 � w'�••• �..+. . .V 11y�
SEEDING DATES: APR1L 1 TO jULY 2"
35.0 LBS. UNHULLED t 0I`-:1IvlON BEFi:1U'DA C--;iRrS;u 1% T 1;: LE:.,:�:..i��
r.rEr.rel. ny�r• JAN'v,_ _1 ' Tv
140.0 LBS. RYE GRASS AT 40 LBS.IACRE (TEMPORARY VEGE TAT [ON)
SEEDING DATES: DECEMBER I TO MARCH 30
14*1-
APPLY THE FOLLOMNO-
35W.0 LBS. OF 10-10-10 FERTILIZER (1000 LBS./ACRE)
7.0 TONS OF DOLOMITIC LIME (2 TONS/ACRE)
.Q B,ALES OF SMALL C-PAIN STIOAV (10D &ALES; ACRE)
ALL SURFACE DRAINS SHOULD BE INSTALLED PRIOR TO SEEDING. SHAPE
ALL DISTURBED AREA'IMMEDIATELYAFTER EARTH MOVING IS COMPLETED.
APPLY LIME AND FERTILIZER THEN DISK TO PREPARE A 3 TO 4 INCH
SMOOTH SEEDBED. APPLY SEEDAND FIR 0 SEEDBED WITH A CULTIPACKER
OR SIMILAR EQUIPMENT. APPLY MULCH AND SECURE WITH A MULCH
ANCHORING TOOL OR NETTING.
1. PENSACOLA BAHIAGRASS 1S SLOWER TO ESTAtUSH THAN COMMON
BERMUDA GRASS. WHEN USING BAHIA, IT IS RECOI`MMENDEDTHAT 8
LBS./ACRE OF COMMON BERMUDA BE INCLUDED TO PROVIDE COVER
UNTIL BAHIAGRASS IS ESTABLISHED.

Lundo► ier/Operulor Nme:
Address-
�'ele�lione:
TA111.0 I - 004 Specifications
IRRIGATION SYSTV, M ICE+'SIGN rARAMUTURS
eri�5 Ue'^ Sdr'
County: do S ) p L,:Zl
Ditle: --7 f�
EXHIBIT D-1
AFproiUnate
Maximmu
- Useable Size
Field' or Fleldl Slope
Number (acres) Soll Tye NO Crop(s)
Afaslmuni
Appllcullon
Itotc3
(inllir)
Afaxbnuni
Appllcatlou
pef IrliCallop
[.`ycic3-
(Inches)
Comments
IT U S�. a- 3,....� a
. y
.5
ti
ISCC allachcci muP.
2Tolal FIC14 acreogc minus required buffer areas. '
3ltc'('cr to ij. C. Irrigation Guide, Field Office Technical Guide, Section II G. Annual applicalion most not exceed the agropomic roles for )lie soil PI)d crop tlsed.
MRCS, NC
TUNE, 1996

EXMU D 3
#�} - Soljq Set jj'i'ISnjjni} ggJ1 Sel lings
hfal;e, 11lodel and Type of Equipment:
Field No)
and Number of
I.Ine No7 Hydrunls
Welled
Diumcler
(feel)
Ilydrunt Spacing (ft)
Along Iietrveeu
1'1}cline Pipelines
Application
pule
{lu/hr
OPERATING PARAMETE16
Nozzle Olreruling Operating
Diuuicler Pressure Time
Inciics a Gun (1s1) !a II dram 1111-i Conuncnls
5
15c
�0
3C)
, r9
'14
C,
s l
Z
Fs
419
'
S c)
3
TO
cl
'Al50
Y6
YO
j5C)
f
jai
gas v
S
.�
�scc allacltc4 map.
?5�io,y separate entries f'or cacti pipeline with hydrants in
each ficlq.
MRCS, NC
TUNE, 1996

TABLE j - Irrigation Syslem Spee ficaliorr9
Traveling
Irrigation Gud
Solid Set
Irri anon
Flosy Rate of Sprinkler (gpm)
13
iterating Pressure at Pump (psl)
! cx
Design Precipitation Rate (inthr)
I C1
1I0se L.engllt (feel)
xxxx xxx
Type of Speed Comiicnsullon
XXXXXXXX
i'uusp Type (PTO, Eugh3e, Electric)
r'Ee or `n � re
Pump Power Requirement (Iip)
15
TABLE. 5 - Thrust Block SpeciftcaliollsI
noduner may nroridn ihrusI 11hWic deletirs nn senorure sheet_
THRUST BLOCK
LOCATION AREA (sq. ff.)
90o Bend 1. 1 T
pcod End j ,�(�
Tee ,(v
'Sec USDA-NRCS Field Mice Technical Guide, Section IV, P►uctice code 430-DI).
r• 0
EXI-HB T DA
NRCS, NC
TUNE, 1996

a.. It
EX]UBIT D-5
MR SY51EM DESIGNER
` Fl,l)
ame: jai v"e t'�l �j eP�r� C 1 0
Coupany:
Address: b x 65c�! _,_ - G
11EQUIREP fl'OCUMENTATION
'11te following details of design and nralerials roust accompany all irrigation designs:
I. A state drawing of the proposed irrigation syslern which includes hydrant locations, travel lanes, pipeline routes, linos( block locations and buffer areas where applicable.
2. Assumptions and corupulations for detennining total dynamic bead and horsepower requirements.
3. Computations used to detennine all mainline and lateral pipe sizes.
�. Sources and/or calculations used for detenuining application rates.
5. Computations used to detennine the size of lhnrst blacks and illustrations of all thrust block configurations required in the system
6. Manufacturer's specifications for llie irrigation pump, traveler and sprinkler(s).
7. Manufacturer's specifications for flan, irrigation pipe and/or USDA-NRCS standard for Irrigation Water Cunl'eyarice,
N.C. Field Office Technical Guide, Seclion IV, Practice Code 130-DD.
8. 111c information rcrliired by this form arc the minimrun ruluircments. It is the responsibility of the designer to consider all relevant factors at a particular site and address there as
appr oprialc.
9. Irrigation pipes should not be installed in lagoon or storage Pond embaukinenls without the approyal of the designer.
NTT: A buffer strip feet wide or wider must be maintained between the limits of the irrigation system and all Perennial
streams oq4 surface waters Per NC Statutes.
MRCS, NC
DUNE, 1996

EXMI T D-b
Narrative of Irrigation System Opertttiou
Desuilxt ilia operation of the sysicus in the space provided below or oil a similar sheet most conviiiiciel to the desi�ncrlsuts4rficr.
lachkde procedures such us start-up, shirt-dovai, wint+wrizution and regular inaiutesmace of uii equipment.
A
711
wF i • Tom• � il��= •�'�
WIM
S f i
NRCS, NC
JUNE, 1996

ri
Y. 6nQl
,
-Y---- -- -- - a� �'� I s 5'°i� ,, � .� �• � � �% s �'b a � -5 � � � �- `�[`� Ssa1 � b}a-i - i
oq
F A'i -EL71
of
L 6')
loll
I
wt)lc'
15C
t
----------- -
C;7 i•..A 40
77

y oL ._ -;W— . , b' x , ocriooa5�4; .
o
L ' L1

State of North Carolina .�
Department of Environment
and Natural Resources 2 5 199'8
Division of Water Quality BUG
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
August 21, 1998
CERTIFIED MAIL
RETURN RIMP—T REQUESTED
Morris Brinson
Brinson Farm
513 A.I. Taylor Rd
Richlands NC 28574
Farm Number: 67 - 84
Dear Morris Brinson:
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL REsouRces
You are hereby notified that Brinson Farm, in accordance with G.S. 143-215.1OC, must apply for
coverage under an Animal Waste Operation General Permit. Upon receipt of this letter,, your farm has
sixty' 60 days to submit the attached application and all supporting documentation. In accordance
withCh pt r-626 of 1995 Session Laws (Regular Session 1996), Section 19(c)(2), any owner or
operator who fails to submit an application by the date specified by the Department SHALL NOT
OPERATE the animal waste system after the specified date. Your application must be returned
within sixty (60) days of receipt of this letter. Failure to submit the application as required may also
subject your facility to a civil penalty and other enforcement actions for each day the facility is operated
following the due date of the application.
The attached application has been partially completed using information listed in your Animal
Waste Management Plan Certification Form. If any of the general or operation information listed is
incorrect please make corrections as noted on the application before returning the application package.
The signed original application, one copy of the signed application, two copies of a general location
map, and two copies of the Certified Animal Waste Management Plan must be returned to complete the
application package. The completed package should be sent to the following address:
North Carolina Division of Water Quality
Water Quality Section
Non -Discharge Permitting Unit
Post Office Box 29535
Raleigh, NC 27626-0535
If you have any questions concerning this letter, please call at [phone] extension or Dave
Holsinger with the Wilmington Regional Office at [phone].
ncerely,
for A. Preston Howard, Jr., P.E.
cc: Permit File (w/o encl.)
Wilmington Regional Office (w/o encl.)
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recyded/ 10% post -consumer paper