670048_HISTORICAL_20171231

NORTH CAROLINA
Department of Environmental Qual

t
Aep
A-
NCDEN
North Carolina Department of Environment and Natural Resources
Pat McCrory John E. Skvarla, Ill
Governor Secretary
October 1, 2014
Morris Brinson
Morris Brinson Farm
513 Al Taylor Rd
Richlands, NC 28574
Subject: Certificate of Coverage No. AWS670048
Morris Brinson Farm
Swine Waste Collection, "Treatment,
Storage and Application System
Onslow County
Dear Morris Brinson:
In accordance with your renewal request, we are hereby forwarding to you this Certificate of Coverage
(COC) issued to Morris Brinson, authorizing the operation of the subject animal waste management
system in accordance with General Permit AWG100000,
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for Morris Brinson Farm, located in Onslow County, with a swine animal capacity of no
greater than the following annual averages:
Wean to Finish: Feeder to Finish: 1224 Boar/Stud:
Wean to Feeder: Farrow to Wean: Gilts:
Farrow to Finish: Farrow to Feeder: Other:
If this is a Farrow to Wean or Farrow to Feeder operation, there may be one boar for each 15 sows. Where
boars are unnecessary, they may be replaced by an equivalent number of sows. Any of the sows may be
replaced by gilts at a rate of 4 gilts for every 3 sows.
This COC shall be effective from the date of issuance until September 30, 2019, and shall hereby void
Certificate of Coverage Number AWS670048 that was previously issued to this facility. Pursuant to this
COC, you are authorized and required to operate the system in conformity with the conditions and
limitations as specified in the General Permit, the facility's CAWMP, and this COC. An adequate system
for collecting and maintaining the required monitoring data and operational information must be
established for this facility. Any increase in waste production greater than the certified design capacity or
increase in number of animals authorized by this COC (as provided above) will require a modification to
the CAWMP and this COC and must be completed prior to actual increase in either wastewater flow or
number of animals.
Please read this COC and the enclosed State General Permit carefully. Please pay careful attention to the
record keeping and monitorinp, conditions in this permit. Record keeping forms are unchanged with this
General Permit. Please continue to use the same record Permit. Please continue to use the same record keepingforms.
1636 Mail Service Center, Raleigh, North Carotina 27699-1636
Phone: 9IM07-6464 I Internet htt�:Rwww.ncdenrgovl
An Equal Opportunity 1 Atrrmative Aclion Empoyer— Made in part by recyded paper

If your Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Per NRCS standards a 100-foot separation shall be maintained between water supply wells and any
lagoon, storage pond, or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CA WMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Program for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition II.22 of the General Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Tropical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You
may find detailed watch/warning information for your county by calling the Newport/Morehead City, NC
National Weather Service office at [phone], or by visiting their website at:
hitp://www.weather.p,ov/mhx/
This facility is located in a county covered by our Wilmington Regional Office. The Regional Office staff
may be reached at 910-796-7215. if you need additional information concerning this COC or the General
Permit, please contact the Animal Feeding Operations Program staff at [phone].
Sincerely,
for Thomas A. Reeder
Director, Division of Water Resources
Enclosure (General Permit AWG100000)
cc: (Certificate of Coverage only for all ccs)
Wilmington Regional Office, Water Quality regional Operations Section
Onslow County Health Department
Onslow County Soil and Water Conservation District
WQROS Central Files (Permit No. AWS670048)
AFO Notebooks
Murphy -Brown LLC

r1 -9111%
NCDENR
North Carolina Department of Environment and Natural Resources
Pat McCrory.
Governor
Morris Brinson
Morris Brinson Farm
513 Ai Taylor Road
Richlands, NC 28574
Dear Moms Brinson:
Division of Water Quality
Charles Wakild, P.E.
Director
February 20, 2013
John E, Skvarla, III
Secretary
Subject: Certificate of Coverage No. AWS670048
Morris Brinson Farm
Swine Waste Collection, Treatment,
Storage and Application System
Onslow County
In accordance with your Notification of Change of Ownership received February 19, 2013, we are hereby
forwarding to you this Certificate of Coverage (COC) issued to Morris Brinson, authorizing the operation
of the subject animal waste management system in accordance with General Permit AWGI00000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's -Certified Animal Waste Management
Plan (CAWMP) for the Morris Brinson Farm, located in Onslow County, with a swine animal capacity of
no greater than the following annual averages:
Wean to Finish: ' Feeder to Finish: 1224 Boar/Stud:
Wean to Feeder: Farrow to Wean: Gilts:
Farrow to Finish: Farrow to Feeder: Other:
If this is a Farrow to Wean or Farrow to Feeder operation, there may be one boar for each 15 sows. Where
boars are unnecessary, they may be replaced by an equivalent number of sows. Any of the sows may be
replaced by gilts at a rate of 4 gilts for every 3 sows.
The COC shall be effective from the date of issuance until September 30, 2014, and shall hereby void
Certificate of Coverage Number AWS670048 dated October 1, 2009. Pursuant to this COC, you are
authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Please pay careful attention to the
record keeping and monitoring conditions in this permit. Record keeping forms are unchanged with this
General Permit. Please continue to use the same record keeping forms.
1636 Mad Service Center, Raleigh. North Carolina 27699-1636
Location:512 N. Salisbury St Raleigh, North Carolina 27604
Phone: [phone] FAX: 919.a7-6492
Internet: www.ncwa uali .o
NorthCarolina
Naturallrf
An Equal opportunity 1 Affirmative Acton Employer

If your Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation of future samples is necessary. - Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Per 15A NCAC 2T .0105(h) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100-foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, then an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior -to aname change: or. change in -ownership.. -,,;-.:.:_--
If any parts, requirements, or limitations contained in ,this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Unit for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition I1.22 of the General Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Tropical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You
may find detailed watch/warning information for your county by calling the Newport/Morehead City, NC
National Weather Service office at [phone], or by visiting their website at:
www.erh.noaa.jzov/er/mhx/
This facility is located in a county covered by our Wilmington Regional Office. The Regional Office
Aquifer Protection Staff may be reached at [phone]. If you need additional information
concerning this COC or the General Permit, please contact the Animal Feeding Operations Unit staff at
[phone].
Sincerely,
Enclosure (General Permit AWG100000)
cc: (Certificate of Coverage only for all ccs)
[Wilmington Regional Office, Aquifer_Protection.Section
Onslow County Health Department
Onslow County Soil and Water Conservation District
APS Central Files (Permit No. AWS670048)
AFO Notebooks
Murphy -Brown, LLC
for Charles Wakild, P.E.
W=cEeVE11
FEB 2 2 286 U
gY:-

f
NCDENIR
North Carolina Department of Environment and Natural Resources
Division of Water Quality Dee Freeman
Beverly Eaves Perdue Coleen H. Sullins Secretary
Governor Director
- June 4, 201-0
Robert B. Mitchell Jr.
Enviro-One
104 Adler Lane
Goldsboro, NC 27530
Subject: Sludge Survey Testing Dates
Enviro-One
Animal Waste Management System
Dear Mr. Mitchell:
The Division of Water Quality (Division) received your sludge survey information for many of your
farms on May 12, 2010. With the survey results, you requested an extension of the sludge survey
requirement for the lagoons at those facilities. Based on the amounts of treatment volume available,
the Division feels that sludge survey requirement exemption is appropriate for the lagoons that are
listed on the attached table for the specified period of time. Please pay particular attention to the
number of years a lagoon is exempt from sludge survey requirement.
Thank you for your attention to this matter. If you have any questions, please call me at (919) 715-
6937. r-_--
Sincerely, i
JUN 0 S- 20 i0
BY;
Miressa . Garoma
Animal Feeding Operations Unit
Attachment: Extension List
cc: Wilmington Regional Office, Aquifer Protection Section
Washington Regional Office, Aquifer Protection Section
Central Files
AQUIFER PROTECTION SECTION
1636 Mail Service Center, Ralegh, North Carolina 27699-1636
Location: 2728 Capital Boulevard. Raleigh, North Carolina 27604
Phone:[phone] FAX 1: 919-715-0588 FAX 2: 919-7 15-6N8 l Customer Service: 1-8 7-623-6748
Internet www.ncwaterquality.crg
Ar: Equal CGpportunity l Afflrma5vc -.ztw Employer
Nord]Caroiina
A7,7tlfrally

Permit NO.
FARM NO.
FARM NAME
LAGOON ID
COUNTY
REGIONAL
SLUDGE SURVEY
Comment
OFFICE
EXTENSION DATE
AWS250020
25-20
Tommy McCoy Livestock
TM-1
Craven
Washington
12/31/2014
AWS250020
25-20
Tommy McCoy Livestock
TM-2
Craven
Washington
12/31/2014
AWS31 4051
31-51
Edwards Tract-B&M #2
1
Duplin
Wilmington
12/31/2010
Extension Denied
AWS31 51
31-51
Edwards Tract-B&M #2
2
Duplin
'Wilmington
12/31/2010
Extension Denied
AWS31 85
31-185
Jim Grady & Sons, Inc.
1
Duplin
Wilmington
12/31/2010
Extension Denied
AWS310212
31-212
Houston Farm
1
Duplin
Wilmington
12/31/2014
'
AWS310212
31-212
Houston Farm
.2
Duplin
Wilmington
12/31/2014
AWS310213
31-213
Long Haul Farms Site #1 & #2
LHF-1
Duplin
Wilmington
1213112014
AWS310213
31-213
Long Haul Farms Site #1 & #2
LHF-2
Duplin
'Wilmington•
12/31/2014
AWS310223
31-223
Westbrook
1
Duplin
Wilmington
12/31/2014
AWS310223
31-223
Westbrook
2
Duplin
Wilmington
12/31/2014
AWS310225
31-225
Pork Krop
1
Duplin
Wilmington
12/31/2010
Extension Denied
AWS310225
31-225
Pork Krop
2
Duplin
Wilmington
12/31/2013
AWS310247
31-247
White Flash
1
Duplin
Wilmington
12/31/2014
AWS310256
31-256
David & Mack Jones
1
Dup[in
Wilmington
12/31/2014
AWS310457
31-457
Pickett's Pigs
1
Duplin'
Wilmington'
12/31/2014
AWS310457
31-457
Pickett's Pigs
2
Duplin
Wilmington
12/31/2014
AWS310517
31-517
William Davis Jr Farm
1
Duplin
Wilmington
12131/2010
Extension denied
AWS310518
31-518
Regina Davis
1
Duplin
Wilmington
12/31/2014
AWS310556
31-556
J&S
1
Duplin
Wilmington
12/31/2014
AWS310580
31-580
David Price
1
Duplin
Wilmington
12/31/2014
AWS310754
31-754
Elsie & Nick Herring
1
Duplin
Wilmington
12/31/2014
AWS310863
31-863
Winters Tract-B.L.Grady
1
Duplin
Wilmington
12/31/2014
AWS400022
40-22
Gray Family. Farms, Inc.
GFF-1
Greene
Washington
12/31/2014
##
i
AWS400099
40-991
Roger Johnson Farm
1
Greene
Washington
12/31/2012
AWS540008
54.81
Davis
1
Lenoir
Washington
12/31/2014
i
AWS540008
54-8..
Davis _..,.- ..,,
:.2.:l , ..:
Lenoir.. F
Washington
"'" 12/31/2014
AWS540008
, 54-8, ,.:...:.
Davis ..._....,_........_ ,._....... _,,.........
... �.,
"3', "Lenoir
�
WaShingfon-� ..:
'12131/2014
AWS540045
54-45
James Wiggins
1
Lenoir
Washington
12/31/2014
AWS540046
54-46
Wiggins Farm Inc
J11
Lenoir
Washington
12/31/2014
AWS540050
54-50
Thurston Wiggins
TW1
Lerioir
Washington
12/31/2014
AWSS40061
54-61
Davis
1
Lenoir
Washington
12/31/2012
AWS540128
54-128
Razorback
RB1
Lenoir
Washington
12/31/2011
AWS670005
67-5.
Cavanaugh Hog Farm
1
Onslow
Wilmington
12/31/2010
Extension Denied
AWS670021
67-21
M R_Hogs
1
Onslow
Wilmington
12/31/2014
AWS670021
67-21,
M R.Hogs
2
Onslow
Wilmington
12/31/2012
Pr'

Permit No.
FARM NO.
FARM NAME'
LAGOON ID
COUNTY
REGIONAL
SLUDGE SURVEY
Comment
OFFICE
EXTENSION DATE
AWS670021
67-21
M R Hogs
3
Onslow
Wilmington
12/31/2014
AWS670048
67-48
M R-MC
-1:.
Onslow
Wilmingtont1213112014�
AWS670087
67-87
H C Farms'. , ..
1 ' "
'Onslow
Wilmington
-
12/31/2014
AWS960010
96-10
Nation
.1
Wayne
Washington
12/31/2014
AWS960011
96-11
Ward Farm
1
Wayne
Washington
12/31/2014
AWS960051
96-51
Daw & Son Farm
1
Wayne
Washington
12/31/2010
Extension Denied
AWS960064
96-64
Kim Gray Farm
KG-1
Wayne
Washington
12/31/2014
AWS960065
96-65
Roland Gray Farm
BG-1
Wayne
Washington
12/31/2014
AWS960073
96-73
Nation
1
Wayne
Washington
12/31/2014
AWS960074
96-74
Lehman G. Smith Farm
LS-1
Wayne
Washington
12/31/2014
AWS960075
96-75
Weaver
1
Wayne
Washington
12/31/2014
AWS960077
96-77
John Dunn Farm
JD-1
Wayne
Washington
12/31/2012
two years only
AWS960092
96-92
Bruce Howell Farm
BH-1
Wayne
Washington
12/31/2012
two years only
AWS960109
96-109
William Britt Farm
WBF-1
Wayne
Washington
12/31/2014
AWS960111
96-111
Lewis
1
Wayne
Washington
12/31/2014
AWS960112
96-112
Outlaw
1
Wayne
Washington
'12/31/2014
AWS960114
96-114
L. Greg Smith, Jr. Farm
GS-1
Wayne
Washington
12/31/2014
AWS960116
96-116
Hood
1
Wayne.
Washington
12/31/2014
AWS960137
96-137
Randy Gray's Isolation
1
Wayne
Washington
12/31/2012
AWS960198
96-198
Beaver Branch Farm
BB-1
Wayne
Washington
12/31/2012
two years only
AWS960198
96-198
Beaver Branch Farm
BB-2
Wayne
Washington
12/31/2014
AWS960204
96-204
William Earl Cruse Farm
WC-1
Wayne
Washington
12/31/2014
AWS960211
96-211
EMS Hog Farms, Inc.
ES-1
Wayne
Washington
12/31/2014
I

State of North Carolina
Department of. Environment
and Natural Resources
Division of, Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
March 16, 2000
MERCER CAVENAUGH
G & C FARM
189 COMFORT ROAD
RICHLANDS NC 28574
/ • •
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Certificate of Coverage No. AWS670048
G&CFarm
Swine Waste Collection, Treatment,
Storage and Application System
Onslow County z
Dear Mercer Cavenaugh:
In accordance with your application received on October 11, 1999, we are forwarding this Certificate of
Coverage (COC) issued to Mercer Cavenaugh, authorizing the operation of the subject animal waste
collection, treatment, storage and land application system in accordance with General Permit
AWG100000. This approval shall consist of the operation of this system including, but not limited to,
the management of animal waste from the G & C Farm, located in Onslow County, with an animal
capacity of no greater than 1224 Feeder to Finish and the application to land as specified in the Certified
Animal Waste Management Plan (CAWMP)_
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS_ 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This request
shall be made within 30 days of notification by the Division.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Certificate of Coverage AWS670048
Shelby Farm -
Page 2
MAR 2 2 2000
This COC is not automatically transferable. A name/ownership change apJuttedto
the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual non -discharge permit by contacting the engineer listed below for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
The subject farm is located in the Wilmington Regional Office. The Regional Office Water Quality Staff
may be reached at [phone]. If you need additional information concerning this COC or the
General Permit, please contact Susan Cauley at [phone] ext. 546.
Sincerely,
I
Kerr T_ Stevens
cc: (Certificate of Coverage only for all cc's)
Onslow County Health Department
Wilmington Regional Office, Water Quality Section
Onslow County Soil and Water Conservation District
Permit File
NDPU Files

WASTE UTILIZATION PLAN
Goldsboro Hog Farms, Inc.
Wednesday, September 12, 2007
Producer: Mark Cavanaugh
Farm Name: MR Hogs -Mark C
P.O. Box 398
Richlands,NC 28574
Telephone # : [phone]e
Type of Operation : Feeder to Finish Swine
Number of Animals : 1224 hogs design capacity
Application Method: Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface and/or groundwater. The plant nutrients in the animal waste should be
used to reduce the amount of commercial fertilizer required for the crops in the fields where
waste is to be applied. This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil tests are strongly
encouraged so that all plant nutrients can be balanced for realistic yields of the crop to be
grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
contents of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and avaialable water holding capacities. Normally waste shall not be applied to
land eroding at greater than 5 tons per acre per year. With special pre -cautions, waste may
be applied to land eroding at up to 10 tons per acre per year. Do not apply waste on
saturated soils, when it is raining, or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed under DEM regulations. Wind
conditions should also be considered to avoid drift and downwind odor problems. To
maximize the value of the nutrients for crop production and to reduce the potential for
pollution, the waste should be applied to a growing crop or applied to bare ground not more
than 30 days prior to planting. Injecting the waste or disking will conserve nutrients and
reduce odor problems. This plan is based on waste application through irrigation for this is
the manner in which you have chosen to apply your waste. If you choose to inject the waste
in the future, you need to revise this plan. Nutrient levels for injecting waste and irrigating
waste are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. Acreage requirements should be based on the waste analysis report
from your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for ananlysis. This waste
utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H.0217 adopted by the Environmental Management Commission.
RECEIVED 1 DENR / DWQ
AQUIFFR-PP0TFr'T10N SECTION
MAR 18 2009
Page 1

AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tans, etc.)
1224 hogs X 1.9 tons waste/hogslyear = 2325.6 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
1224 hogs X 2.3 Ibs PANlhogslyear = 2815.2 PAN/year
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on the crop to be grown,
soil type and suface application.
TABLE I: ACRES OWNED BY PRODUCER
TRACT FIELD SOIL TYPE &CLASS-
CROP
YIELD LBS AW COMM ACRES
LBS Aw APPLIC.
DETERMINING PHASE
CODE
NIACRE NIACRE
USED TIME
3098
-AR-MC1
ISTALLINGS
5G
1
5Q
0
8.96
448
SEP-MAY
3098
MR-MC1
STALLINGS
BH
5.5
275
01
8.961
2464
MAR-OCT
TOTALS:
2912
Indicates that this field is being overseeded (i.e. interplanted) or winter annuals follow
summer annuals.
* Indicates a Crop Rotation
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N
requirments. Beginning in 1996 the Coastal Zone Management Act will require farmers in
some eastern counties of NC to have a nutrient management plan that addresses all
nutrients. This plan only addresses Nitrogen.
Page 2

TABLE 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land. See required specifications 2.)
There are no Acres Leased
Indicates that this field is being overseeded (i.e. interplanted) or winter annuals follow
summer annuals.
* Indicates a Crop Rotation
* Acreage figures may exceed total acreage in field due to overseeding.
**Lbs AW N (animal waste nitrogen) equals total required nitrogen less any commercial
nitrogen (COMM N) supplied.
The following legend explains the crop codes used in TABLES 1 and 2 above:
CROP CODE CROP UNITS LBS N/UNIT
8H I HYBRID BERMUDAGRASS-HAY TONS 50
SG SMALL GRAIN OVERSEEDED �AC 1 50
Page 3

TOTALS FROM TABLES 1 AND 2
ACRES LBS AW
N USED
TABLE 1 8,961 2,912
TOTALS: 8.96 2,912
AMOUNT OF N PRODUCED: 2,815
" BALANCE -97
I This number must be less than or equal to 0 in order to fully utilize the animal waste N
produced.
Acres show in each of the preceeding tables are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter
areas not receiving full application rates due to equipment limitations. Actual total acres in the
fields listed may, and most likely will be, more than the acres shown in the tables.
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of
sludge at agronomic rates. The sludge will be nurturient rich and will require precautionary
measures to prevent over application of nutrients or other elements. Your production facility
will produce approximately 452.88 pounds of plant available nitrogen (PAN) per year in the
sludge that will need to be removed on a periodic basis. This figure is PAN when
broadcasting the sludge. Please be aware that'additional acres of land, as well special
equipment, may be needed when you remove this sludge.
See the attached map showing the fields to be used for the utilization of waste water.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the soil at the time of
irrigation such that runoff or ponding occurs. This rate is limited by initial soil moisture
content, soil structure, soil texture, water droplet size, and organic solids. The application
amount should not exceed the available water holding capacity of the soil at the time of
irrigation nor should the plant available nitrogen applied exceed the nitrogen needs of the
crop.
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every 5.92 months. In no instance should the volume of
waste being stored in your structure be within 1.8 feet of the top of the dike.
If surface irrigation is the method of land application for this plan, it is the responsiblity of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in Tables 1 and 2. Failure to apply the recommended rates and
amounts of Nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application rates and amounts.
APPLICATION APPLICATION
TRACT FIELD SOIL TYPE CROP RATE (Inlhr) AIVIT (inches)
3098
1 --MR-MCI
STALLINGS
SG
1 0.60
1 -1
3098
I MR -MCI
ISTALLINGS
BH
1 0.50
1 '1
* This is the maximum application amount allowed for the soil assuming the amount of
nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Page 4

NARRATIVE OF OPERATION
This WUP was revised April, 2007 to reflect Grower changing zones from six zones to One
Zone. Grower can now pump all sixty heads at one time.All wettable information was
provided by Bill Norris with SWCD.Overseed was changed to 50lbs.
Page 5

PLANS & SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited. Illegal discharges are subject
to assessment of civil penalties of $10,000 per day by the Division of Water Quality for every
day the discharge continues.
2. The Field Office must have documentation in the design folder that the producer either
owns or has long term access to adequate land to properly dispose of waste. If the producer
does not own adequate land to properly dispose of waste, he shall provide NRCS with a copy
of a written agreement with a landowner who is within a reasonable proximity, allowing
himther the use of the land for waste application for the life expectancy of the production
facility. It is the responsibility of the owner of the facility to secure an update of the Waste
Utilization Plan when there is a change in the operation, increase in the number of animals,
method of utilization, or available land_
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for realistic
crop yields based on soil type, available moisture, historical data, climate conditions, and
level of management, unless there are regulations that restrict the rate of application for other
nutrients.
4. Animal waste may be applied to land that has a Resource Management System (RMS) or
an Alternative Conservation System (ACS). If an ACS is used the soil loss shall be no greater
than 10 tons per acre per year and appropriate filter strips will be used where runoff leaves
the field. These filter strips will be in addition to 'Buffers" required by DEM. (See FOTG
Stantard 393 - Filter Strips and Standard 390 Interim Riparian Forest Buffers).
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland, the
waste may be broadcast provided the application does not occur during a season prone to
flooding_ (See "Weather and Climate in North Carolina" in the NRCS Technical Reference -
Environment file for guidance.)
*7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
runoff does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control conditions
conducive to odor or flies and to provide uniformity of application.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with
a high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste shall
not be applied more than 30 days prior to planting of a crop on bare soil.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following:
the outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
Page 6

and from any perennial str ' am or river (other that an irrigation ditch or canal. Animal waste
other than swine waste from facilities sited on or after October 1, 1995), shall not be applied
closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal Waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landownwer.
14. Waste shall be applied lin a manner not to reach other property and public right - of ways.
15. Animal waste shall not ¢e discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted croplands
provided they have been approved as a land application site by a "technical specialist".
Animal waste should not be applied on grassed waterways that discharge directly into water
courses, except when applied at agronomic rates and the application causes no runoff or drift
from the site.
*16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc.,
shall not be discharged into the animal waste management system.
*17. A protective cover of a
propriate vegetation will be established on all disturbed areas
(lagoon embankments, berms,
pipe runs, etc.). If needed, special vegetation shall be
provided for these areas ar
d shall be fenced, as necessary, to protect the vegetation.
Vegetation such as trees, shrubs,
and other woody species, etc. are limited to areas where
considered appropriate. Lagoon
areas should be kept mowed and accessible. Lagoon berms
and structures should be inspected
regularly for evidence of erosion, leakage or discharge.
*18. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining a d implementing a "closure plan" which will eliminate the possibility
of an illegal discharge, poll�tion and erosion.
*19. Waste handling struct res, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdo s, leaks, and spills. A regular maintenance checklist should be
kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied as a preemergence with no other applications of
animal waste during the crop season.
*21. Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to mark
the maximum storage volume fpr waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least
annually at crop sites where waste products are applied. Nitrogen shall be the rate -
determining element. Zinc and copper levels in the soils shall be monitored and alternative
crop sites shall be used when these metals approach excessive levels. pH shall be adjusted
for optimum crop production amd maintained. Soil and waste analysis records shall be kept
for five (5) years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina Department of
Page 7

NAME OF FARM: MR Hogs -Mark C
OWNER 1 MANAGER AGREEMENT
I (we) understand and will follow and implement the specifications and the operation and
maintenance precedures estalished in the approved animal waste utilization plan for the farm
named above. I (we) know that any expansion to the existing design capacity of the waste
treatment and/or storage system or construction of new facilities will require a new utilization
plan and a new certification to be submitted to DEM before the new animals are stocked.
(we) understand that I must own or have acces to equipment, primarily irrigation equipment,
to land apply the animal waste described in this waste utilization plan. This equipment must
be available at the appropriate pumping time such that no discharge occurs from the lagoon
in a 25-year 1-day storm event. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates that no runoff occurs.
NAME OF FACILITY OWNER:9 'ZCavanaugl
SIGNATURE: A/ C DATE:
NAME OF MANAGER (if different from owner):
please print
SIGNATURE:
DATE:
NAME OF TECHNICAL SPECIALIST:. Robert B. Mitchell Jr.
AFFILIATION: Private Technical Specialist
ADDRESS (AGENCY):
104 Adler Lane
Goldsboro, NC 27530
[phone]
SIGNATURE: DATE:
Page 9

7 -418
�OF W A TF�p Michael F, Easley, Governor
i67v7_,.
William G. Ross Jr., Secretary
rolina Department of Environment and Natural ResourcesO Alan W. Klimek, P. E., Director
2004 Cofeen H. Sullins, Deputy Director
Division of Water Quality
June 28, 2004
Mark Cavenaugh
M R Hogs
M R Hogs Farm
PO Box 398
Richlands, North Carolina 28574
Subject: Certificate of Coverage No. AWS670048
M R Hogs Farm
Swine Waste Collection, Treatment,
Storage and Application System
Onslow County
Dear Mr. Cavenaugh:
In accordance with your Notice of Change of Ownership received on May 25, 2004 we are hereby
forwarding to you this Certificate of Coverage (COC) issued to M R Hogs, authorizing the operation of
the subject animal waste collection, treatment, storage and land application system in accordance with
General Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the M R Hogs Farm, located in Onslow County, with an animal capacity of no
greater than an annual average of 1224 Feeder to Finish swine and the application to land as specified in
the facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or
Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary,
they may be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a
rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until October 1, 2004, and shall hereby void
Certificate of Coverage Number AWS670649 dated May 1, 2003: Pursuant to this COC, you are
authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC_ An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Perrr&tee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
fi RA
ENR
Non -Discharge Permitting Unit Internet http:/lh2o.enr.state.nc.us/ndpu
1617 Mail Service Center, Raleigh, NC 27699-1617 Telephone [phone] Fax [phone]
Customer Service Center Telephone 1-B77-623-6748
An Equal Opportunity Action Employer 50% recycled/10% post -consumer paper

Mr._Mark.Cavenaugh-
Page 2
June 28, 2004
Per MRCS standards a 100 foot separation shall be maintained between water supply wells and any
lagoon or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application. must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Wilmington Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Duane Leith at [phone] ext. 370.
Sincerely,
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
Mercer Cavenaugh
CWilmington RegionarofFze, Wa er QuaIiiy..5Fc-Li n
Onslow County Health Department
Onslow County Soil and Water Conservation District
Permit File AWS670048
NDPU Files

o�o� wAr�Rp�
Michael F. Easley
Governor
William G. Ross Jr., Secretary
Department of Environment and Natural Resources
fl Alan W. Klimek, P.E. Director
Division of Water Quality
April 16, 2003
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Mercer Cavenaugh
189 Comfort Road
Richlands NC 28574
SUBJECT: Notice of Violation
Request for Information
Inadequate Freeboard
G & C Farm
#67-48
Onsiow County
Dear Sir or Madam:
On April 10, 2003, a representative of your animal operation informed the Division of
Water Quality (DWQ) that there was inadequate freeboard in the lagoon(s) serving this facility.
This lack of adequate freeboard is in non-compliance with the Certificate of Coverage
issued to this facility on March 16, 2000. In addition to .this Notice of Violation (NOV), this
non-compliance is subject to an appropriate enforcement action by DWQ. This action can
consist of one or more of the following: a civil or criminal enforcement action; an injunction;
and/or a requirement to apply for coverage under an individual permit. The action chosen will
be based on complete evaluation of all factors that resulted in the inadequate freeboard; the
actions taken to restore the needed freeboard; and the actions being proposed to prevent the
problem from reoccurring.
To assist -us in our review, please provide the Wilmington Regional Office with an
evaluation of the reasons for the freeboard violation(s) and a strategy to prevent future freeboard
violation(s). This evaluation and strategy must include but is not limited to the following:
Current Freeboard level(s)
Freeboard level records in the lagoon(s) for the past 12 months up to the date of submittal
Spraying records for the past 12 months up to the date of submittal
lNN EIR
Customer Service. Mailing Address. Telephone [phone] Location:
1-877-623-6748 1617 Mail Service Center Fax [phone] N. Salisbury St.
Raleigh, North Carolina 27699-1617 State Courier #52-01-01 Raleigh, NC 27699-1617
An Equal Opportunity/Affirmative Action Employer
50% recycled / 10% post -consumer paper
ht1pl/h2o. enrstate.nc. us

Inadequate Freeboard
Page t
Rainfall records for the past 12 months for this site up to the date of submittal (if
available)
Cropping system and PAN specified in the CAWMP. If the cropping system was not in
compliance with the facility's CAWMP, provide details of the cropping system in place
for the past 12 months.
A summary of actions taken to restore the needed freeboard in the lagoon(s)including but
not limited to removal of animals from the site, delay of restocking of animals, pumping
and hauling waste to another site (specify site), securing additional -irrigation equipment,
and securing additional spray sites.
A description of water conservation measures in use at the facility and the date(s)
installed.
If the lagoon level(s) are still in violation of the facility's CAWMP and Permit, provide
an updated Plan of Action as to how the facility will return to compliance.
Provide a detailed description of the actions taken or proposed to be taken to insure that
there are no further freeboard violations at this facility.
This information must be received by the Wilmington Regional Office at the following
address no later than 10 days following receipt of this letter.
Division of Water Quality
127 Cardinal Drive Extension
Wilmington, NC 28405-2845
Once this information is received and evaluated by the DWQ staff, a determination will
be made as to the appropriate compliance/enforcement actions to be taken. Each case will be
evaluated on its own merit. The efforts by the owner/producer to notify DWQ of the problem,
efforts made to resolve the problem once identified, and efforts proposed to prevent future
problems will be positive factors in this determination.
Nothing in this letter should be taken as removing from you either the responsibility or
liability for this non-compliance or future cases of non-compliance. If you have any questions
regarding this letter, please do not hesitate to contact our Wilmington Regional Office Staff at
[phone].
Sincerely,
lan W. Klimek, P.
Director
cc: Wilmington Regional Office
Non -Discharge Compliance/Enforcement Unit
Central Files

A
July 24, 2003
Mercer Cavenaugh
189 Comfort Road
Richlands, NC 28574
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Subject: Rescission of Notice of Violation /
- Issuance of Notice of Deficiency
G&CFarm
Facility 4 67-48
Onslow County
Dear Mercer Cavenaugh:
Alan W. Klimek, P.E. Director
Division of Water Quality
Thank you for your recent submittal of the information requested in our letter dated April 15,
2003. We greatly appreciate the effort that you made in compiling this information and sending
it to our Wilmington Regional Office by the date required. We also appreciate the fact that you
reported the problem with high freeboard to our staff as required by your permit and worked with
our staff to manage the problem once it occurred.
Upon review and consideration of information submitted, the Wilmington Regional Office
has determined that no further compliance/enforcement actions will be taken by the Division for
these high freeboards.
Also, based on your actions to properly operate your facility, the Division of Water Quality
hereby rescinds the Notice of Violation that was issued to you on April 15, 2003 and replaces it
with this Notice of Deficiency.
In the future, please continue to evaluate ways to maintain freeboard levels in the required range.
These methods include, but are not limited to, water conservation practices, adding additional
application sites, updating your cropping systems, adding additional and/or more flexible
application equipment, and maintaining the lagoon levels at the lowest allowable and appropriate
levels throughout the year. Our staff looks forward to continuing to work with you and your
Technical Specialist to evaluate and implement any needed changes to your system.
ZWW
NCDE 'R
Customer Service: Mailing Address: -- - - - - - -Telephone: [phone] -- Location: -
1 800 623-7748 1617 Mail Service Center Fax: [phone] N. Salisbury St.
Raleigh, NC 27699-1617 State Courier #52-01-01 Raleigh, NC 27699-1617
An Equal Opportunity / Affirmative Action Employer
50% recycled / 10% post -consumer paper
http://h2o.enr. state. nc. us

Inadequate Freeboard
Mercer Cavenaugh--
July 24, 2003
Page 2
Thank you again for your cooperation. if you have any questions, please do not hesitate to
contact the staff of our Wilmington Regional Office at 910-395-3900.
Sincerely,
Rick Shiver
... Water Quality Regional Supervisor... _
CC: Donna Card, Onslow County Soil and Water Conservation District
Kraig Westerbeek, Murphy -Brown, LLC
Patrick Fussell, DSWC
Wilmington Files 67-48
Non -Discharge Compliance and Enforcement Unit
Central Files

State of North Carolina
Department of Envirom
and Natural Resources
JUN 12 COOT
Michael F. Easley, Govern4_8Y:
William G. Ross Jr., Secretary -
Kerr T. Stevens, Director
June 4, 2001
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Mercer Cavenaugh
G & C Farm
189 Comfort Road
Richlands NC 28574
4 LT?WA
IT
•
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Notification for Wettable Acre Determination
Animal Waste Management System
G & C Farm
Facility Number 67-48
Onslow County
Dear Mercer Cavenaugh:
A letter dated January 15, 1999 was sent to advise you about concerns associated with Certified Animal
Waste Management Plans and the method by which the irrigated acres within the plans were calculated. Only
the acres that are wetted can be credited in the waste management plan as receiving waste application. Any
acreage within the plan that can not be reached by waste application equipment can not be used as part of your
plan.
An evaluation by Dean Hunkele on 4/13/99 was made to review the actual number of acres at your
facility that receive animal waste during land application. The evaluation of your facility has yielded one of
the following two results as indicated by the box marked with an "X".
Category 1::
EK The evaluation of your facility could not be completed due to a lack of information. Please
contact your Technical Specialist to assist in providing Dean Hunkele the necessary
information to potentially exempt your facility from undergoing a complete wettable acre
determination. Please submit this information to Dean Hunkele, at 127 Cardinal Drive
Extension, Wilmington, NC 28405-3845, within in 90 days of the receipt of this letter. If you
have any questions please contact Dean Hunkele at [phone]. If within 90 days you
are unable to provide Dean Hunkele with the information you ,are automatically
required to complete a Wettable Acre Determination as described by Category 2
below, within 180 days of receipt of this letter.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
. An Equal Opportunity Affirmative Action Employer 50% recycied/10% post -consumer paper

Notification for Wettable Acre Determination
Animal Waste Management System
Page 2
Category 2:
❑ Your facility has been identified by the Department of Environment and Natural Resources
as a facility that may have overestimated the number of acres actually receiving animal
waste. Therefore, some or all of your fields may be exceeding the allowable loading rates
set in your Certified Animal Waste Management Plan.
In order to resolve this issue, please contact a designated Technical Specialist to have him
or her conduct a Wettable Acre Determination for your facility. The Technical Specialist must
be one that has been approved by the Soil and Water Conservation Commission to conduct
Wettable Acre Determinations. Many Technical Specialist with the N.C. Cooperative Extension
Service, the Soil and Water Conservation Districts, the Natural Resources Conservation
Service, and the Division of Soil and Water Conservation have received this special
designation. You may also contact a private Technical Specialist who has received this
designation, or a Professional Engineer.
All needed modifications to your Animal Waste Management System must be made and
the Wettable Acres Determination Certification must be returned to DWQ within the next
180 days. If the needed modifications are not made and if the form is not returned within the
required time, DWQ will be forced to take appropriate enforcement actions to bring this facility
into compliance. These actions may include civil penalty assessments, permit revocation,
and/or injunctive relief.
Once a Wettable Acre Determination has been completed, a copy of the attached Wettable
Acre Determination Certification must be submitted to the address listed on the form. Please
note that both the owner and the Technical Specialist must sign the certification. A copy of all
the Wettable Acre Determination documentation that applies to your Waste Utilization Plan
must be kept at your facility. DWQ and the Division of Soil & Water Conservation Staff will
review all documentation during their annual visit of your facility. An additional copy must by
kept on file at the local Soil & Water Conservation District Office. Please note that if you install
or modify your irrigation system, a designated Irrigation Specialist or a Professional Engineer
must also sign the Wettable Acre Determination Certification.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Sonya Avant of our
Central Office staff at [phone] ext. 571.
Sincerely,
Kerr T. Stevens
cc: Wilmington Regional Office
Onslow County Soil and Water Conservation District
Facility File
Murphy Family Farms

State of North Carolina ly
Department of Environment RECEIVED 4 • 0
and Natural Resources
Division of Water Quality JAN 13 2000
James B. Hunt, Jr., Govemor BY: NCDENR
- Bill Holman, Secretary - - - — -- Nc*zTH CAROLINA DE-ARTMENT OF
Kerr T. Stevens, Director ENVIRONMENT AND NATURAL RESOURCES
January 7, 2000
MERCER CAVENAUGH
G & C FARM
189 COMFORT ROAD
RICHLANDS NC 28574
Subject: Application No. AWS670048
Additional Information Request
Shelby Farm
Animal Waste Operation
Onslow County
Dear Mercer Cavenaugh:
The Non -Discharge Permittina Unit has completed a preliminary engineering review of the subject application. Additional
information is required before we can continue our review. Please address the following by February 6, 2000.
The Waste Utilization Plan (WUP), the Insect and Odor Control and Mortality Management Checklists, and
the Emergency Action Plan must be signed and dated by the current owner.
2. According to the WUP a rye overseed may be utilized in field #1 for late fall and early spring nutrient
applications. Please contact your technical specialist in order to include the amount of nitrogen in pounds per
acre that can be utilized by the rye overseed according to the specific soil type present. The total amount of
nitrogen applied to the Bermuda hay and rye overseed cannot exceed 400 pounds of nitrogen per acre since
this amount of nitrogen exceeds the current recommendation of 275 pounds per acre (5.5 pounds/ton * 50
tonslacres) for Stallings soil.
Your Waste Utilization Plan (WUP) lists the application window for Bermuda as April through September.
The Sixth Guidance Memorandum to Technical Specialist dated August 18, 1997 states that the last
application of animal waste is to be applied to Bermuda prior to August 31 and that an additional 50 pounds
per acres of Plant Available Nitrogen (PAN) can be applied to the small grain between September 15 and
October 30 and also from February to March. Please have your technical specialist revise the application
window on the Bermuda to April through August or incorporate the memorandum into Table 1 for the
Bermuda crop also.
Please note that all V UP revisions must be signed and dated by both the owner and the technical specialist. Please
reference the subject permit application number when providing the requested information. All information should be signed,
sealed, and submitted in duplicate to my attention at the address below. The information requested by this letter must be
submitted on or before February 6, 2000 or the Division will return your application as incomplete in accordance with 15A
N.C.A.C. 2H .0200 and your facility will be considered to be operating without a permit.
Please be advised that operation of the subject animal waste management system without a valid permit is a violation of North
Carolina General Statute 143-215.1 and will subject you to the enforcement authority of the Environmental Management
Commission. 4
If you have any questions regarding this request, please call me at [phone], extension 546.
Sincerely,
��C
san Cauley
Environmental Engineer
Non -Discharge Permitting Unit
cc: Wilmington Regional Office, Water Quality
Permit File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

State of North Carolina
Department of Environs
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Govei
Bill Holman, Secretary
Kerr T. Stevens, Director
Mercer Cavenaugh
Shelby Farm
189 Comfort Road
Richlands NC 28574
Dear Mercer Cavenaugh:
ent
J AN 0 3 2000
aY:
NCDENR
NOR-rH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
December 30, 1999
Subject: Fertilizer Application Recordkeeping
Animal Waste Management System
Facility Number 67-48
Onslow County
This letter is being sent to clarify the recordkeeping requirement for Plant AvaiIable Nitrogen (PAN)
application on fields that are part of your Certified Animal Waste Management Plan.
In order to show that the agronomic loading rates for the crops being grown are not being exceeded, you
must keep records of all sources of nitrogen that are being added to these sites. This would include nitrogen
from all types of animal waste as well as municipal and industrial sludges/residuals, and commercial fertilizers.
Beginning January 1, 2000, all nitrogen sources applied to land receiving animal waste are required to
be kept on the appropriate recordkeeping forms (i.e. IRR1, IRR2, DRY1, DRY2, DRY3, SLUR1, SLUR2,
SLD 1, and SLD2) and maintained in the facility records for review. The Division of Water Quality (DWQ)
compliance inspectors and Division of Soil and Water operation reviewers will review all recordkeeping during
routine inspections. Facilities not documenting all sources of nitrogen application will be subject to an
appropriate enforcement action.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Ms. Sonya Avant of the
DWQ staff at [phone] ext. 571.
Sincerely,
Kerr T. Stevens, Director
Division of Water Quality
cc. Wilmington Regional Office
Onslow County Soil and Water Conservation District
Facility File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10%n post -consumer paper

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
.fames B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
September 15, 1999
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Mercer Cavenaugh
Shelby Farm
189 Comfort Road
Richlands NC 28574
Farm Number: 67 - 48
Dear Mercer Cavenaugh:
61'rM.MA
IT 0 0
A&44
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
You are hereby notified that Shelby Farm, in accordance with G.S. 143-215.1 OC, must apply for coverage under an
Animal Waste Operation General Permit. Upon receipt of this letter, your farm has sixty (60) days to submit the attached
application and all supporting documentation. In accordance with Chapter 626 of 1995 Session Laws (Regular Session
1996), Section 19(c)(2), any owner or operator who fails to submit an application by the date specifed by the
Department SHALL NOT OPERATE the animal waste system after the specified date. Your application must be
returned within sixty (60) days of receipt of this letter. Failure to submit the application as required may also subject your
facility to a civil penalty and other enforcement actions for each day the facility is operated following the due date of the
application.
The attached application has been partially completed using information listed in your Animal Waste Management
Plan Certification Form. If any of the general or operation information listed is incorrect please make corrections as noted on
the application before returning the application package. The signed original application, one copy of the signed application,
two copies of a general location map, and two copies of the Certified Animal Waste Management Plan must be returned to
complete the application package. The completed package should be sent to the following address:
North Carolina Division of Water Quality
Water Quality Section
Non -Discharge Permitting Unit
1617Mail Service Center
Raleigh, NC 27699-1617
If you have any questions concerning this letter, please call Susan CauIey at [phone] extension 546 or Brian
Wrenn with the Wilmington Regional Office at [phone].
Sincerely,
for Kerr T. Stevens
cc: Permit File (w/o encl.)
Wilmington Regional Office (w/o encl.)
1617 Mail Service Center, Raleigh, NC 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled110% post -consumer paper

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
Mercer Cavenaugh
Shelby Farm
189 Comfort Road
Richlands NC 28574
Dear Mercer Cavenaugh:
1 61W?o •
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
December 30, 1999
Subject: Fertilizer Application Recordkeeping
Animal Waste Management System
Facility Number 67-48
Onslow County
This letter is being sent to clarify the recordkeeping requirement for Plant Available Nitrogen (PAN)
application on fields that are part of your Certified Animal Waste Management Plan.
In order to show that the agronomic loading rates for the crops being grown are not being exceeded, you
must keep records of alCsources:of nitrogen that are being added to these sites. This would include nitrogen
from all types of animal waste as well as municipal and industrial sludgeshesiduals, and commercial fertilizers.
Beginning January 1, 2000, all nitrogen sources applied to land receiving animal waste are required to
be kept on the appropriate recordkeeping forms (i.e. IRR1, IRR2, DRY1, DRY2, DRY3, SLUR1, SLUR2,
SLD1, and SLD2) and maintained in the facility records for review. The Division of Water Quality (DWQ)
compliance inspectors and Division of Soil and Water operation reviewers will review all recordkeeping during
routine inspections. Facilities not documenting all sources of nitrogen application will be subject to an
appropriate enforcement action.
Please be -advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Ms. Sonya Avant of the
DWQ staff at [phone] ext. 571.
Sincerely, �f
' DC
Kerr T. Stevens, Director
- - Division of Water Quality
cc: Wilmington Regional Office
Onslow County Soil and Water Conservation District
Facility File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

State of North Carolina
Department of Environment and Natural Resources
Division of Water Quality
Non -Discharge Permit Application Form
(THIS FORM MAY BE PHOTOCOPIED FOR USE AS AN ORIGINAL)
General Permit - Existing Animal Waste Operations
The following questions have been completed utilizing information on file with the Division. Please
review the information for completeness and make any corrections that are appropriate. If a
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
1. GENERAL INFORMATION:
1.1 Facility Name: ShellnrVakn G 4- C F,Z r ,m
1.2 Print Land Owner's name: Mercer Cavenaugh
1.3 Mailing address: 189 Comfort Road
City, State: Richlands NC Zip: 28574
Telephone Number (include area code): 910-324-2296
1.4 County where facility is located:
1.5 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a copy
of a county road map with the location of the farm identified): West of Richlands. Farm is on West side of SR 1301
a rox. 2 miles North of SR 1300.
1.6 Print Farm Manager's name (if different from Land Owner):
1.7 Lessee's / Integrator's name (if applicable; please circle which type is listed): Murphy Family Farms
1.8 Date Facility Originally Began Operation: 01/01/92
1.9 Date(s) of Facility Expansion(s) (if applicable):
2. OPERATION INFORMATION:
2.1 Facility No.: 67 (county number); 48 (facility number).
2.2 Operation Description: Swine operation
Feeder to Finish
1224- Certified Design Capacity.
Is the above information correct? yes; Q no. if no, correct below using the design capacity of the facility
The "No. of Animals" should be the maximum number for which the waste management structures were designed.
Type of Swine
• Wean to Feeder
• Feeder to Finish
• Farrow to Wean (# sow)
• Farrow to Feeder (# sow)
• Farrow to Finish (# sow).
No. of Animals Type of Poultry No. of Animals ape of Cattle No. of Animals
/Z Z
Other Type of Livestock on the farm:
• Layer • Dairy
• Non -Layer • Beef
• Turkey
No. of Animals:
FORM: AWO-G-E 5/28/98 Page 1 of 4 67 - 48

2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): 7.38 ; Required Acreage (as listed in the AWMP): 7.2
2.4 tuber of aI go gAstorage ponds (circle which is applicable):
2.5 re subsurface drains present within 100' of any of the application fields? YES or A
please circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? VI S orplease circle one)
2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, NRCS Standards, etc.) (Swine Only)
or NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited? Z � a -0/
What was the date that this facility's land application areas were sited? '-Z 8' _ 99
3. REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit application
for animal waste operations.
The CAWMP must include the following components. Some of these components may not
have been required at the time the facility was certified but should be added to the
CAWMP for permitting purposes:
3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application.
3.3.4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application field.
3.3.8 The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.3.10 A site schematic.
3.3.11 Emergency Action Plan.
3.3.12 Insect Control Checklist with chosen best management practices noted.
3.3.13 Odor Control Checklist with chosen best management practices noted.
3.3.14 Mortality Control Checklist with the selected method noted.
3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility.
3.3.16 Operation and Maintenance Plan.
If your CAWMP includes any components not shown on this list, please include the
additional components with your submittal.
FORM: AWO-G-E 5/28/98 Page 2 of 4 67 - 48
Applicants Initials
r�^r
v

r
Facility Number: 67 - 48
Facility Name: Shelby Farm
4.
I,
(Land Owner's name listed in question 1.2), attest that
this application for e! d -(Facility name listed in question t.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all requir upporting information and attachments are not included, this application package
will be returned tame as incomplete!
Signature era%'��� Date
5. MANAGER'S CERTIFICATION: (complete only if different from the Land Owner)
I,
(Manager's name listed in question 1.6), attest that this
application for (Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be returned as incomplete.
Signature
Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
1617 MAIL SERVICE CENTER
RALEIGH, NORTH CAROLINA 27699-1617
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
FORM: AWO-G-E 5/28/98 Page 3 of 4 67 - 48

DIVISION OF WATER QUALITY REGIONAL OFFICES (1/98)
Asheville Regional WQ Supervisor
59 Wood& Place
Asheville, NC 28901
(szg) 251.6208
Fax (e 2g) 251-6452
Avery Macon
Buncombe Madison
Burke
McDowell
Caldwell
Mitchell
Cherokee
Polk
Clay
Rutherford
Graham
Swain
Haywood
Transylvania
Henderson
Yancey
Jackson
Fayetteville Regional WQ Supervisor
Wachovia Building, Suite 714
Fayetteville, NC 28301
(910) 486-154I
Fax (910) 48"707
Anson
Moore
Bladen
Richmond
O nabedaad
Robeson
Harm
Sampson
Hake
Scotland
Montgomery
Winston-Salem Regional WQ SupmvUar
585 W&DOtown Street
Winston-Salem, NC 27107
(33Q 771-4600
Fax Gj3 ) 771-4631
Alamaaae Rockingham
Alleghany Randolph
Axbe SU*=
Caswell Surry
Davidson Wataatga
Davie Wilkes .
FaMA Yawn
Gailfcrd
Washington Regional WQ Supervisor
943 Washington Square Mall
Washington, NC 27989
(25z) qVI-6481
Fax (95a; 975-3716
Beaafort ' Janes
Berde - Lenoir
Cbowan
Pamlico
Craven
Pasquotaak
CmTitack
P=gdmans
Dare
Pitt
Gates
Tyrell
Greene
Washington
Hertford
Wayne
Hyde
Mooresville Regional WQ Supervisor
919 North Main Street
Mooresville, NC 28115
[phone]
Fax [phone]
Alexander Lincoln
Cabarrus Mecklenburg
Catawba Rowan
Cleveland Stanly
Gaston Union
Iredell
-IWeigb Regional WQ Supervisor
38W Barrett Dr.
Raleigb. NC 27611
[phone]
Fax [phone]
Cbis am Nash
Durham NaithnnVton
Edgar mbe Orange
Franklin Person
Granville Vance
Halifax wake
Johnston Warren
Lae Wilson
Wilmington Region- WQ Supervisor
127 CatdirW Drive Extension
Wilmington. NC 29405-3945
[phone]
Fax [phone]
Brunswick New Hanover
Carteret Onslow
Columbus " Peader
Duplin
FORM: AWO-G-E S/2W8
Page 4 of 4

IN
' wAT RFCE/ V��
OPERATION & MAINTENANCE PLAN QUAi7-ySECno'V
n^-
Proper lagoon liquid management should be a year-round priority. It is especially VL7. j
important to manage levels so that you do not have problems during extended rainy and 199
wet periods.
Maximum storage capacity should be available in the lagoon for periods when the ng
receiving crop is dormant (such as wintertime for bermudagrass) or when there are
extended rainy spells such as the thunderstorm season in the summertime. This means
that at the first signs of plant growth in the later winter/early spring, irrigation according to
a farm waste management plan should be done whenever the land is dry enough to
receive lagoon liquid. This will make storage space available in the lagoon for future wet
periods. In the late summer/early fall the lagoon should be pumped down to the low
marker (see Figure 2-1) to allow for winter storage_ Every effort should be made to
maintain the lagoon close to the minimum liquid level as long as the weather and waste
utilization plan will allow it.
Waiting until the lagoon has reached its maximum storage capacity before starting to
irrigate does not leave room for storing excess water during extended wet periods.
Overflow frorn the lagoon for any reason except a 25-year, 24-hour storm is a violation of
state law and subject to penalty action.
The routine maintenance of a lagoon involves the following:
Maintenance of a vegetative cover for the dam.
Fescue or common bermudagrass are the most common vegetative
covers. The vegetation should be fertilized each year, if needed, to
maintain a vigorous stand. 'I'lre amount of fertilizer applied should be
based on a soils test, but in the event that it is not practical to obtain
a soils test each year, the lagoon embankment and surrounding areas
should be fertilized with 800 pounds per acre of 10-10-10, or
equivalent.
Brush and trees on the embankment must be controlled. This may be
done by mowing, spraying, grazing, chopping, or a combination of
these practices. This should be done at least once a year and
possibly twice in years that weather conditions are favorable for
heavy vegetative growth.
NOTE: If vegetation is controlled by spraying, the herbicide must riot be allowed to enter
the lagoon water. Such chemicals could harm the bacteria in the lagoon that are treating
the waste.
Maintenance inspections of the entire lagoon should be made during the initial fdUng of
the Iagoon and at least monthly and after major rainfall and storm events. Items to be
checked should include, as a minimum, the following:
Waste Inlet Pipes, Recycling Pipes, and Overflow Pipes ---look for:
1. separation of joints
2. cracks or breaks
3. accumulation of salts or minerals
4. overall condition of pipes

Lagoon surface --look. for:
1. undesirable vegetative growth
2. floating or lodged debris
Embankment ---look for:
1_ settlement, cracking, or "jug" holes
2. side slope stability —slumps or bulges
3. wet or damp areas on the back slope
4. erosion due to lack of vegetation or as a result of wave action
5. rodent damage
Larger lagoons may be subject to liner damage due to wave action caused by strong
winds. These waves can erode the lagoon sidewalls, thereby weakening the lagoon dam.
A good stand of vegetation will reduce the potential damage caused by wave action. If
wave action causes serious damage to a lagoon sidewall, baffles in the.lagoon may be
used to reduce the wave impacts.
Any of these features could lead to erosion and weakening of the dam: If your lagoon has
any of these features, you should call an appropriate expert familiar with design and
construction of waste lagoons. You may need to provide a temporary fix if there is a threat
of a waste discharge. However, a permanent solution should be reviewed by the
technical expert. Any digging into a lagoon dam with heavy equipment is a serious
undertaking with potentially serious consequences and should not be conducted unless
recommended by an appropriate technical expert.
Transfer Pumps ---check for proper operation of:
1. recycling pumps
2. irrigation pumps
Check for leaks, loose fittings, and overall pump operation. An unusually loud or grinding
noise, or a large amount of vibration, may indicate that the pump is in need or repair or
replacement_
NOTE: Pumping systems should be inspected and operated frequently enough so that you.
are not completely "surprised" by equipment failure. You should perform your -pumping
system maintenance at a time when your lagoon is at its low Ievel. This will allow some
safety time should major repairs be required. Having a nearly full lagoon is not the time
to think about switching, repairing , or borrowing pumps. Probably, if your lagoon is full,
your neighbor's Igoon is full also. You should consider maintaining an inventory of spare
parts or pumps.
Surface water diversion features are designed to carry all surface
drainage waters (such as rainfall runoff, roof drainage, gutter outlets,
and parking lot runoff) away from your lagoon and other waste
treatment or storage structures. The only water that should be
coming from your lagoon is that which comes from your flushing
(washing) system pipes and the rainfall that hits the lagoon directly.
You should inspect your diversion system for the following:
1. adequate vegetation
2. diversion capacity
3. ridge berm height

Identified problems should be corrected promptly. It is advisable to inspect your system
during or immediately following a heavy rain. If technical assistance is needed to
determine proper solutions, consult with appropriate experts.
You should record the level of the lagoon just prior to when rain is predicted, and then
record- the level again 4 to 6 hours after the rain (assumes there is no pumping). This will
give you an idea of how much your lagoon level will rise with a certain rainfall amount
(you must also be recording your rainfall for this to work). Knowing this should help in
planning irrigation applications and storage. If your lagoon rises excessively, you may
have an inflow problem from a surface water diversion or there may be seepage into the
lagoon from the surrounding land.
Lagoon Operation
Startup:
l_ Immediately after constriction establish a complete sod cover on bare soil
surfaces to avoid erosion.
2. Fill new lagoon design treatment volume at least half full of water before
waste loading begins, taking care not to erode lining or. bank slopes.
3. Drainpipes into the lagoon should have a flexible pipe extender on the
end of the pipe to discharge near the bottom of the lagoon during initial
filling or another means of slowing the incoming water to avoid erosion of
the lining.
4. When possible, begin loading new lagoons in the spring to maximize
bacterial establishment (due to warmer weather).
5. It is recommended that a new lagoon be seeded with sludge from a healthy
working swine lagoon in the amount of 0.25 percent of the full lagoon
liquid volume. This seeding should occour at least two weeks priorto the
addition of wastewater.
6. Maintain a periodic check on the lagoon liquid pH. If the pH falls below
7.0, add agricultural lime at the. rate of 1 pound per 1000 cubic feet of
lagoon liquid volume until the pH rises above 7.0. Optimum lagoon liquid
pH is between 7.5 and 8.0.
7. A dark color, Iack of bubbling, and excessive odor signals inadequate
biological activity. Consultation with a technical specialist is recommended
if these conditions occur for prolonged periods, especially during the wazm
season.
Loading:
The more frequently and regularly that wastewater is added to a lagoon, the better the
lagoon will function. Flush systems that wash waste into the lagoon several times daily are
optimum for treatment. Pit recharge systems, in which one or more buildings are drained -
and recharged each day, also work well.

A1M=geMentz
Practice water conservation —minimize building water usage and
spillage from leaking -waterers, broken pipes and washdown through
proper maintenance and water conservation.
Minimize feed wastage and spillage by keeping feeders adjusted. This
will reduce the amount of solids entering the lagoon
Maintain lagoon liquid level between the permanent storage level and
the full temporary storage Ievel.
Place visible markers or stakes on the lagoon bank to show the
minimum liquid level and the maximum liquid lever (Figure 2-1).
Start irrigating at the earliest possible date in the spring based on
nutrient requirements and soil moisture so that Yemporary storage
will be maximized for the summer thunderstorm season. Similarly,
irrigate in the late summer/early fall to provide maximum lagoon
storage for the winter.
The lagoon liquid level.should never be closer than 1 foot to the lowest
point of the dam or embankment.
Do not pump the lagoon liquid level lower that the permanent storage
level unless you are removing sludge.
Locate float pump intakes approximately 1$ inches underneath the liquid
surface and as far awav from the drainpipe inlets as possible.
Prevent additions of bedding materials, long-stemmed forage or -vegetation,
molded feed, plastic syringes, or other foreign materials into the lagoon -
Frequently remove solids from catch basins at end of confinement houses or
wherever they are installed.
Maintain strict vegetation, rodent, and varmint control near lagoon edges_
Do not allow trees or large bushes to grow on lagoon dam or embankment
Remove sludge from the lagoon either when the sludge storage capacity is
full or before it fills 50 percent of the permanent storage volume.
If animal production is to be terminated, the owner is responsible for
obtaining and implementing a closure plan to eliminate the possibility of 2-
pollutant discharge.
Sludge Removal:
Rate of lagoon sludge buildup can be reduced by:

proper lagoon sizing,
mechanical solids separation of flushed waste,
gravity settling of flushed waste solids in an appropriately designed basin, or
minimizing feed wastage and spillage.
Lagoon sludge that is removed annually rather than stored long term will:
have more nutrients,
have more odor, and
require more land to properly use the nutrients.
Removal techniques:
Aire a custom applicator.
Mix the sludge and lagoon liquid with a chopper -agitator impeller
pump through large -bore sprinkler irrigation system onto nearby cropland;
and soil incorporate.
Dewater the upper part of lagoon by irrigation onto nearby cropland or
forageland; mix remaining sludge; pump into liquid sludge applicator; haul
and spread onto cropland or forageland; and soil incorporate.
Dewater the upper part of lagoon by irrigation onto nearby cropland or
forageland; dredge sludge from lagoon with dragline or sludge barge; berm
an area beside lagoon to -receive the sludge so that liquids can drain bacl:
into lagoon; allow sludge to dewater; haul and spread with manure spreader
onto cropland or forageland; and soil incorporate.
Regardless of the method, you must have the sludge material analyzed for waste
constituents just as you would your lagoon water. The sludge will contain different
nutrient and metal values from the liquid. The application of the sludge to fields will be
limited by these nutrients as well as any previous waste applications to that field and crop
requirement. Waste application rates will be discussed in detail in Chapter 3.
When removing sludge, you must also pay attention to the liner to prevent damage. Close
attention by the pumper or drag -line operator will ensure that the lagoon liner remains
intact_ If you see soil material or the synthetic liner material being disturbed, you should
stop the activity immediately and not resume until you are sure that the sludge can be
removed without liner injury. if the liner is damaged it must be repaired as soon as
possible -
Sludge removed from the lagoon has a much higher phosphorus and heavy metal content
than liquid. Because of this it should probably be applied to land with low phosphorus
and metal levels. as indicated by a soil test, and incorporated to reduce the chance of
erosion. Note that if the sludge is applied to fields with very high soil -test phosphorus, it
should be applied only at rates equal to the crop removal of phosphorus. As with other
wastes, always have your lagoon sludge analyzed for its nutrient value.
The application of sludge will increase the amount of odor at the waste application site.
Extra precaution should be used to observe the wind direction and other conditions which
could increase the concern of neighbors.

�J
Possible Causes of Lagoon Failure
Lagoon failures result in the unplanned discharge of wastewater from the structure. Types
of faiiiu-es include leakage through the bottom or sides, overtopping, and breach of the
dam. Assuming proper design and construction, the owner has the responsibility for
ensuring structure safety. Items which may lead to lagoon failures include:
Modification of the lagoon structure ---an example is the placement of a pipe
in the dam without proper design and construction_ (Consult.an expert in
lagoon design before placing any pipes in dams_)
Lagoon liquid levels —high levels.are a safety risk.
Failure to inspect and maintain the dam.
Excess surface water flowing into the lagoon -
Liner integrity —protect from inler pipe scouxing, damage during sludge
removal, or rupture from lowering lagoon liquid level below groundwater
table.
NOTE: If lagoon water is allowed to overtop the dam, the moving water -will soon cause
gullies to form in the dam. Once this damage starts, it can quickly. cause a large discharge
of wastewater and possible dam failure.

EMLAGENCY ACTION PLAN
PHONE NUMBERS
DIVISION OF WATER QUALITY (DWQ) q ID 34 5 39 d(:!>
EMERGENCY MANAGEMNET SERVICES (EMS) 1 fU 34.-1 _! (D
SOIL AND WATER CONSERVATION DISTRICT (SWCD) �ilv� 115 y�7a
NATURAL RESOURCES CONSERVATION SERVICE (NRCS) 91011,55 q -7a
COOPERATIVE EXTERSION SERVICE (CES)' 1455
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing or running off site. You should not wait until wastes reach surface waters
or leave you property to consider that you have a problem. You should make every
effort to ensure that this does not happen. This plan should be posted in an accessible
location for all employees at the facility. The following are some action items you should
take-
1. Stop the release of wastes. Depending on the situation, this may ore may not be
possible. Suggested responses to some possible problems are listed belwo.
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B. Runoff from waste application field -actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that cause the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
D. Leakage from flush systems, houses, solid separators -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed
to flowing leaks -possible action:
a. Dig a small sump or ditch from the embankment -to catch all
seepage, put in a submersible pump, and pump back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and. lagoon
bottom as soon as possible.
1-

2. Assess the extent of the spill and note any obvious damages.
a. Did the waste. reach any surface waters?
b. Approximately how much was released and for what duration?
c. Any damage notes, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours call your DWQ regional office; Phone - -. After
hours, emergency number: 919-733-3942. Your phone call should include: your
name, facility number, telephone number, the details of the incident from item 2
above, the exact location of the facility, the location or direction of movement of
the spill, weather and wind conditions. The corrective measures that -have been
under taken, and the seriousness of the sitution.
b. If spill leaves property or enters surface waters, call local EMS phone number.
c.. Instruct EMS to contact local Helath Department_
d. Contact CEs, phone number - , local SWCD office phone number - -, and local
NRCS office for advice/technical assistance phone number - -.
4. If none of the above works call 911 or the Sheriff's Department and explain you
Problem to them and ask the person to contact the proper agencies for you.
5. Contact the contractor of your choice to begin repair or problem to minimize off -
site damage.
a. Contractors Name:
b. Contractors Address
c. Contractors Phone:
6. Contact the technical specialist who certified the lagoon (NRCS, Consulting
Engineer, etc.)
a. Name: _LLa
b. Phone: 91b
7. Implement procedures as'advised by DWQ and technical assistance agencies to
rectify the damage, repair the system, and reassess the waste managment plan to
keep problems with release of wastes from happening again.
2

INSECT CONTROL CHECKLIST FOR ANIMAL OPERATIONS
Source Cause 9MP's to Minimize Odor Site Spec Practices
(Liquid Systems)
Flush Gutters Accumulation of solids t Fluah system is designed and operated
sufficiently to remove accumulated
� �//solids from gutters as designed.
Kfiemove bridging of accumulated solids at
discharge
Lagoons and Pits Crusted Solids
("aintain lagoons, settling basins and
Pits where pest breeding is apparent to
minimize the crusting of solids to a depth
of no more then 6-8 inches over more than
30% of surface.
Excessive Vegetative Decaying vegetation
w-m: nt"in vegetative control along banks of
Growth
lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along water's edge on impoundment's perimeter.
(Dry Systems)
Feeders Feed Spillage
{ I Design, operate and maintain feed systems
bunkers and troughs) to minimize the accumulation
of decaying wastage.
(} Clean up spillage on 9 routine basis (e.g. 7-10 day
interval during summer, 15-30 day interval during wirroar).
Feed Storage Accumulations of feed residues () Reduce moisture accumulation within and around
immediate perimeter of feed storage areas by
insuring drainage away from site and/or providing
adequate containment (e.g.. covered bin for
brewer's grain and similar high moisture grain
products).
() inspect for and remove or break up accumulated
solids in filter strips around feed storage es needed.
Animal Holding Areas Accumulations of animal wastes { } Eliminate low area that trap moisture along fences
and feed wastage and other locations where waste accumulates and
and disturbance by artimeis is minimal.
() Maintain fence rows and filter strips around animal
holding areas to minimize accumulations of wastes
(i.e. inspect for and remove or break up accumulated
solids as needed).
MIC—November 11. 1996

Dry Manure Handling Accumulations of animal wastes { Remove spillage on a routine basis (e.g. 7-10 day
Systems interval during surwner, 15-30 days interval during
winter) where manure is loaded for land application
or dieposa!_
() Provide for adequate drainage around manure stockp&m.
{) Inspect for and remove or break up accumulated wastes
In Ifiter stripes around stockpiles and manure handrng
areas so needed_
The issues checked (} pertain to this operation. The landowner/integrator agrees to use sound judgment in -applying
insect control measures as practical.
I certify the aforementioned insect control Best' Management- Practices have been reviewed with me.
(Landowner Sig ature)
For more information contact the Cooperative Extension Service, Department of Entomology. Box 7613,.North Caroline State Utiversiry, Raleigh, NC
27995-7613.
AMC —November 11, 1996

SWINE FARM WASTE MANAGEMENT ODOR CONTROL CHECKLIST
Source
Cause
BMf 's to Minimize Odor Site Specific Practices
Farmstead
Swine production
t'i Vegetative or wooded buffers.
{4401commended best management
�rnetices;
{ )/Good judgment and common sense
Animal body surfaces
dirty manure -covered animals
(-2 Ury floors
Floor surfaces
Wet manure -covered floors
(-/ lotted floors;
01" Waterers located over slotted floors;
ff) ceders at high and of solid floors;
( ),8crepe manure buildup from floors;
(} Underfloor ventilation for drying
Manure collection pits
Urine
{oVfrequent manure removal by flush pit
recharge.or scrape
Parital micorbial decomposition (} Underfloor ventilation
Ventilation exhaust tans Volatile gases;
maintenance;
Dust Utfficient air movement
Indoor surfaces Dust { Washdown between groups of animals
{) Feed additives;
f ] Feeder covers;
(} Feed delivery downspout extenders to
feeder covers
Rush tanks Agitation of recycled lagoon (} Flush tank covers
liquid whiles tanks ere filling (] Extend fill lines to near bottom of
tanks with anti -siphon vents
Rush alleys Agitation during wastewater {) Underfloor flush with underfloor
conveyanenee ventilation
Pit recharge points Agitation of recycled lagoon {) Extend rechard lines to near bottom of
liquid while pits are filling pits with anti -siphon vents
Lift stations
Agitation during sump tank filling
{) Sump tank.covers
and drewdown
Outside drain collection
Agitation during wastewater
{) Box covers
or jurtctien boxes
conveyance .
End of drainpipes at lagoon
Agitation during wastewater
( ) Extend discharge point of pipes
underneath lagoon liquid level
Lagoon surfaces
Volatile gas emissions -
(Proper lagoon liquid capacity .
Biological mixing
Correct lagoon startup procedures
Agitation
( )�neimum surface area -to -volume ratio
( j' "nimurn Agitation when pumping
( ) Mechanical aeration
{ I Proven biological additives
irrigation sprinkler notes High pressure agitation ( r Pgate on dry days with little or no wind
Wind draft (fA rw_ �}mum recommended operation pressure
Pump intAke near lagoon liquid surface
( ) Pump from second -stage lagoon
AMOC—November 11. 1996

Storage tank or basin Partial microbial decompasition
() Bottom or midlevel loading
surface Mixing while filling
( } Tank covers
Agitation when emptying
{ J Basin surface mats of solids
() Proven biological additives or oxidants
Settling basin surface Partial micebial decomposition
(} Extend drainpipe outlets underneath liquid
Mixing while filling
level
Agitation when emptying
(} Remove settled solids regularly
Manure, slurry or sludge Agitation when spreading [) Soil infection of slurry/sludges
spreader outlets Volatile gas emissions (J Wash residual manure from spreader after use
{ } Proven biological additives or oxidants
Uncovered manure, slurry Volatile gas emissions while drying ( ) Soil infection of slurry/sludges
or sludge on field surfaces
(} Soil incorporation within 48 hours
{ J Spread in thin uniform layers for rapid drying
(] Proven biological additives or oxidants
Dead animals Carcass decomposition ( "Proper disposition of carcasses
Dead animal disposal Carcass decomposition (] Complete covering of carcasses in burial pits
pits (} Proper location/construction of disposal pits
Incinerators Incomplete combustion (} Secondary stock burners
Standing water around Improper drainage ( Grade and landscape such that water drains
facilities Microbial decomposition of away from facilities
organic matter
Manure tracked onto public Poorly maintained access roads ,('Farm access road maintenance
roads from farm access
Additional information: Available From:
Swine Manure Management; 0200 Rule/BMP Packet
NCSU-County Extension Center
Swine Production Farm Potential Odor Sources and Remedies, EBAE Fact Sheet
NCSU-BAE
Swine Production Facility Manure Management: Pit Recharge —Lagoon Treatment; EBAE 128-88
NCSU-8AE
Swine Production Facility Manure Management: Underfloor Fluse—lagoon Treatment; EBAE 129-88
NCSU-BAE
Lagoon Dasig and Management for Livestock Manure Treatment and Storage; EBAE 103-83
NCSU-BAE
Calibration of Manure and Wastewater Application Equipment; EBAE Fact Sheet
NCSU-BAE
Controlling Odors from Swine Buildings; PIN-33
NCSU-Swine Extension
Environmental Assuranc Program: NPPC Manuel
NC Pork Produces Assoc
Dptions for Managing Odor: a report from the Swine Odor Task Force
NCSU Agrf Conmtunications
Vuissnee Concerns in Animal Manure Menevement: Odors and Flies; PRO107, 1995 Conference Proceedings Florida Cooperative Extension
The issues checked ( 1 pertain to this operation. The landowner/integrator agrees to use sound judgment in applying
idor control measures as practical.
certify the aforementioned odor control Best Managment Practices have been reviewed with me.
11-2ndowner nature)
AOC—November 11, i996

MORTALITY MANAGEMENT METHODS
(check which method(s) are being implemented)
{ ) Burial three feet beneath the surface of the ground within 24 hours
after knowledge of -the death. The burial be at least 300 feet from
any flowing steam or public body of water.
(� Rendering at a rendering plant licensed under G. S. 106-168.7
( ) Complete incineration
{ j In the case of dead poultry only, placing in a disposal pit of a size and
design approved by the Department of Agriculture.
( j Any method which in the professional opinion of the State
Veterinarian would make possible the salvage of part of a dead
animal's value without endangering human or animal health. (Written
approval of the State Veterinarian must be attached)

1 2 3
/• y Jr
256
c
A f�� ojrF�S Hti� R D. r' / lib*
.Pb * �o Huffmantown o - %�
ALORZA armantow
�, �w cAvaN4U�y,,P6tersbu :t
Prochs / !
Haw _0 TES v WARR p. 1 ,�
s UISELk•' F i �� ERSB p, C,TO u
�trr vrClF 24 Ric c4N o i
y14yo [N Cpx j1 ICK z
4V s 4
PV. I RD • BROS
��O 1 !N 1
5` HOFFA{gH
r
+o LANDS obit�� O w n �)
ad . OpN
�f a rf*f� �mm c I nds
/ r % ! C9 P% R �PODSOff
SCH. RD. B9,q
: Grp o y
coo . :'�4 eA (q,, �N2 A >� mod' p� ° • I.ROCK CREEII DR.
t r Q► f z.DAiSYCT.--
i a•
�, 1 �kANE Ct.
2 I. O I S.JDY Cr.
6,PLgYERCC
o r sc+ x VENTERS 8
OLF
cou UB° ��• -
I 1 _ ,k l lCQ • IL LA S{� 0.� C' _ I 1
LPICKiNiN.fi� ` �yffY IELO<��,
t TRIM! LN. D ¢ 00
C f \* BACK SWb 9y, w �i
pEw V.F.D. @� cF3o�o3 Po s D. RICH LN. W°rF r' O
epty �O' :1 �ti¢ +MACx 4'Qy-p. Q� '��`'o'.oca pAlTO
LIV a �o r z c, pIy r v
All
HOO�tiyN
EUZ G ALBERT ELLS p "Y �. �o- J' V.F.D Ra. gay ! �t
�9t �PORT� a�'f` kS\ s LAKtRD. 3� itro d4 pR 4 �0 0 ALF MC
d 5owo 5 LM k` COASTAL PLAINS` t1•R
if 4 GRACE $ e��Wog$ zo �� r DRA[7ISTER
�F= _ / RR y S
fr LAP R5�
r qr 1 9 y h ��c7 . RFp " 50� �a4�� HER + 0� cn `�� �y p6°A4
Flo JQ i f�Y�OEa �� Qa m �+�� Qo' a p� g�
9 *ILLIAMS
AR f Tad'
RD. I RD BE /� / F� LOOP RD. \ PONY FAR R0.
WEET LN. NINE Eo p. N y HOBBRSO y a anding
- yla _. wsA [1Y- _ ,� _ _ A ! ll
_ r jr
V �P KS(
Wit; HEr�iTT 4 �
S�o. Fn QrQ co
4 �; a !i �'i
0 .�O _ _ ` n a Q gp. 'x CREEK . R6 258
gROY ASPEN o 2_}x o - -_ __•�: �vS
53
y i 00y
y 'yt
south VV Fd
♦ l ? P COOT DAVIS Mp Cree*
�C9 R0. xp o R S CR EK ryly'
1 r 90 0J Cyrus o`" °yya�HA4O�P.R •�FS,�Q�oTrIILLRI R £sj r o Y r
i� .dhCouno• {t HCRKRIRD.. t/�A.S yA9 _✓FO RD ♦`� y/ @fin M1 CURTIS R

Producer: 11 A J, 4 a'Ja4
Location: 5 o r &%Arc. 1ZJ.
Telephone: Q/a - 3z t4 - YV B %
Type Operation: F�►S�.��rg
Number of Animals: /-LLq
(Design Capacity)
( 51•s i 61 FARE)
R;��,�na•{s, JJ. C. z 95-7V
rCr rCsV
[OCT ' f f999
IVort Discharge pefrrFit�n�
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface and/or groundwater. -The plant nutrients in the animal waste should
be used to reduce the amount of commercial fertilizer required for the crops in the fields
where the waste is to be applied. This waste utilization plan uses nitrogen as the limiting
nutrient. Waste should be analyzed before each application cycle. Annual soil tests are
strongly encouraged so that all plant nutrients can be balanced for realistic yields of the
crop to he grown.
Several factors are important in implementing your waste utilization plan in order to
maximize the fertilizer value of the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply more nitrogen than the crop
can utilize. Soil types are important as they have different infiltration rates, leaching
potentials, cation exchange capacities, and available water holding capacities.. Normally
waste shall not be applied to land eroding at greater than 5 tons per acre per year. With
special precautions, waste may be applied to land eroding at up to 10 tons per acre per
year. Do not apply waste on saturated soi]s, when it is raining, or when the surface is
frozen. Either of these conditions may result in runoff to surface waters which is not
allowed under DEM regulations. Wind conditions should also be considered to avoid drift
and downwind odor problems. To maximize the value of nutrients for crop production
and to reduce the potential for pollution, the waste should be applied to a growing crop or
applied to bare ground not more than 30 days prior to planting. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. Acreage requirements should be based on the waste analysis
report from your waste management facility. Attached you will find information on
proper sampling techniques, preparation, and transfer of waste samples to the lab for
analysis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A
NCAC 2H.0217 adopted by the Environmental Management Commission.

'z:sii iz y c :.c a a
;aKI
� :z a .
... �,...
Antount of Waste Produced Per Year(gallons, ft3, toms, etc)
/Z,?,q animals X L(amt.) waste/animal/year =7-3 i-G (amt.) waste/year.
Amount of Plant Available Nitrogen (PAN) Produced Per Year
/as-`� animals Xz.i lbs. PAN/animal/year =4Ibs. PAN/year. (PAN from N. C. Tech.
Guide Std. 633)
Applying the above amount of waste is a big job. You should plan time and have
appropriate equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on the crop to he grown
and surface application:
Table 1: ACRES OWNED BY PRODUCER
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
* This N is from animal waste only. If nutrients from other sources such as commercial
fertilizer are applied, they must be accounted for. N must he based on realistic yield
expectation.
NOTE. The applicator is cautioned that P and K maybe over applied while meeting the N
requirements. Beginning in 1996 the Coastal Zone Management Act will require farmers in
some eastern counties of North Carolina to have a nutrient management plan that addresses
all nutrients. This plan only addresses Nitrogen.
2
i

Table 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowner must be attached)
(Required only if operator does not own
adequate land [see Required Specification 2])
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
* See footnote for Table 1.
Totals from above Tables
Acres Lbs. N
Utilized
Table I
Table 2
Total
Amount of N
Surplus oCO-(
7.3
2-2 L o
-7.3.
z9zo
Produced
zg ig
10
NOTE: The Waste Utilization Plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient rich and will
require precautionary measures to prevent over application of nutrients or other
elements
3

See attached map showing the fields to be used for the utilization of wastewater.
Application of Waste by Irrigation
Field Soil Type Crop Application Application
No. Rate (In4k) Amount (In.
THIS TABLE IS NOT TIDED IF WASTE IS NOT BEING APPLIED BY IRRIGATION, HOWEVER A SENMAR TABLE WILD
BE NM)ED FOR DRY LITTER OR SLURRY.
Your facility is designed for 1ga days of temporary storage and the temporary storage
must be removed on the average of once everyMONTHS. In no instance should
the volume of waste being stored in your structure exceed Elevation
Call the local Natural Resources Conservation Service (formerly Soil Conservation
Service) or Soil and Water Conservation District office after you receive the waste
analysis report for assistance in determining the amount per acre to apply and the proper
application rate prior to applying the waste.
Narrative of
EId a
j
g%o As ar0- Acrn_ tokS Also "c 4no►,- )A-J.
4

WASTE UTILIZATION PLAN AGREEMENT
Name of Fann: r tLr,
Owner/Manager Agreement
I (we) understand and will follow and implement the specification and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. I (we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new facilities will require a new
certification to be submitted to the Division of Environment Management (DEM) before
the new animals are stocked. I (we) also understand that there must be no discharge of
animal waste from this system to surface wasters of the state from a storm event less
severe than the 25-year, 24-hour storm The approved plan will be filed on -site at the
farm office and at the office of the Iocal Soil and Water Conservation District and will be
available for review by DEM upon request.
Name of Facility Owner: -p¢d y J to tj t d
(Please print)
Signature: d1j,. Date:
Name of Manager(If different from owner):
Signature:
Date:
Name of Technical Specialist: (Please print)-,a� K CYAk
Affiliation:- - L,a.,
Address (Agency): rid.
c.
Signature: Date: C9 - /a - S�

SOIL SURVEY OF ONSLOW SHEET NUM
COUNt NORTH CAROLINA
W K.
am
Cin
R�
MaC
-�\ Nop Ql� I'[.,

0_'*t"
Notification of Change of Ownership
Animal Waste Management Facility Wq��C�1 V�O
(Please type or print all infomiation that does act require a signature) i�U` r'ySt C;i0&j
In accordance with the requirements of 15A NCAC 214 _0217(a)(1)(H)(xii) this IPOR is10 icjal
notification to the Division of Water Quality (DWQ) of the transfer of ownership&f an Animal ante
Management Facility. This form must be submitted to DEM no later than 60 days followiitg.iihe; transfer
of ownership. v G-'mllling
Ge�ral Into-r—mation:
Name of Farm: !SlAe 16 rel f - ^•_ - - FacilityNo: G 7 -_ y y
Previous Owner(s) Name-i�r� kaa�� __ _ Phone No: q_ t0_ 3 dy y4$S
New Owner(s) Name: fficrce e Phone No:
Mailing Addirss: 4
Farm Location: Fourteen Digit Hydrologic Unit: 0 3a3 o a 6 1 d I oa
Latitude and Longitude: 3 f % 55 0 ' / :L7_ X __o '" County: o r► s I b
Please attach a copy of a county road map with location identified and describe below (Be specific_ road
names, directions, milepost, etc.): V-01ke 1jc a05 e:AWS1 -
J
7�pe of Swine No. of Animals Type of Poutrry No. of Anunals Type of Cattle No_ of Animals
Wean to Feeder ❑ Layer ❑ Dairy
Seeder to Finish 1 a at _ ❑ PotlCts ❑ Beef
O Farrow to Wean
Farrow to Feeder
0 Farrow to Finish Other Type of Livestock:Number of Animals:, -
I;
40�0�
Acreage Available for Application: 73 $ Required Acreage: ? 7
Number of Lagoons f Storage Ponds: Total Capacity: Cubic Feet (ft3)
Owner f Manager Agreement
I (we) verify that all the above information is correct and will be updated upon changing. I (we) understand the operation and
maintenance procedures established in the approved aninmf waste management plan for the farm named above and will
implement these procedures. I (we) know that any expansion to the existing design capacity of the waste treatment and
storage system or construction of new facilities will require a new certification to be submitted to the Division of Water
Quality (DWQ) before the new animals are stocked. I (we) understand that there must be no discharge of animal waste from
the storage or application system to surface waters of the state either directly through a mart -made conveyance or from a storm
event less severe than the 25-year. 24-hour storm and there trust not be run-off from the application of animal waste. I (eve)
understand that run-off of pollutants from lounging and heavy use areas must be minimized using technical standards
developed by the Natural Resources Conservation Service. The approved plan will be filed at the farm and at the office of the
local Soil and Water Conservation District. t (we) know that any modification most be approved by a technical specialist and
submitted to the Soil and Water Couservaft 'District prior to implementation. change in land ownership requires written
notification to DWQ or a new certificate the appr?ved plan is c ed) h- 60 days of a title transfer.
Name of New L Owner :
Signaiure• � ��Zt'L r •i2' lrY� C- Date•. - %
.—T-
Name of arTager(if different from owner):
Signature: Date:
Please sign and return this form to: N.C. Division Of Water Quality
Water Quality Section, Compliance Group
Raleigh, NC 27626-11535
.P*

l�prs R� A�� FD
Animal Waste Management Plan Certification E r oi�r
(Please type or print all information that does not require a signature), Ocr. I f CA —
General
information: �. rge Pefttung
Name of Farm: G & C Farm Facility No: 67 - 48 -
Owner(s) Name: Mercer Cavanaugh Phone No: 910-324-2296
Mailing Address: P.O. Box 964 _Richlands. NC 28574
Farnr Location: Fourteen Digit Hydrologic Unit: 03030001010020
Latitude and Longitude: 34' 53' 00" / 771 34' 10" County: ONSLOW
Please attach a copy of a county road map with location identified and describe below (Be specific: road
names, directions, milepost, etc.): From Beulaville. take NC 24 E towards Richlands; from Onslow Co line
go 3.5 nulcs further on NC 24 E to stop ligW at intersection of US 258 then turn Right on SR1300 for 1.1
mile; turn left on SR 1301 and go 2.0 miles to farm entrance on left
Overation Description:
Type of Srvine No. of Animals
❑ Wean to Feeder
0 Feeder to Finish 1224
❑ Farrow to Wean
❑ Farrow to Feeder
❑ Farrow in Finisli
Type of Poultry No. of Animals
❑ Layer
❑ Pullets
Other Thpe of l,ivestoc:k:
Type of Cattle No. of Animals
❑ Dairy
❑ Beef / O
Number gfAnirnals:
xa r r
t �. 1'r z'T.v----`�� -� - `z��r�^� �"x^�•.a .�^"�-a^:.9r^ �z _ rx �.-,
Pr evrous�Desrgn:Capar:rty p - r At7drttanal Design cla actiO _ - = •w -
x
s "aR i�
;, _. ._ '� 3T�S��'Y,%.�`z"': :iY" ..,-1- 'C"'Y .ST4-.Y..d"'S IC.,% Y"'—.'} TF3. "T7'T3" .S•.w.. [r i "1�" .d1 7'^',^
-Tiatal�-
Acreage Available for Application: 7.38 Required Acreage: 7.2
Number of Lagoons I Storage Ponds: I Total Capacity: -Z Cubic Feet (fl)
Are subsurface drains present on the farm: YES or(1 (please circle one)
If YES: are subsurface drains present in the area of the LAGOON or SPRAY FIELD (please circle one)
Owner / Manager Agreement
(we) verify that all lire above information is correct and will be updated upon changing. I (we) understand the operation and
maintenance procedures established in the approved animal waste management plan for the farm named above and will implement
these procedures. I (we) know that any expansion to the existing design capacity of the waste treatment and storage system or
construction of new facilities will require a new certification to he suhmitled to tire Division of Environmental Management before the
new animals are stocked. I (we) understand that there must be no discharge of animal waste from the storage or application system to
surface waters of the state either directly through a man-made conveyance for from a storm event less severe than the 25-year. 24-hr
storm and there rrmst not be run-off rfoul the application of animal waste. I (we) understand that run-off of pollutants from lonngina
and heavy use areas must be minimized using technical standards developed by the Natural Resources Conservation Service. The
approved plan will be filed at the farm and at the office of the local Soil and Water Conservation District. I (we) know that any
modification must be approved by a technical specialist and suhmittecl to the Soil and Water Conservation District prier to
implementation. A change in land ownership requires written notification to DEM or a new certification (if the approved plan is
changed) within 60 days of a title transfer,
Name of Land
Signature: Date: _ Fir
.01
-
Nanic of A'lanaecr (it diflercnt fr
_ ner):
Signature:
AWC -- January 1, 1997
Date:
ore ow
_
r-7

Technical Specialist Certification
I As a technical specialist designated by the North Carolina Soil and Water Conservation Commission
pursuant to 15A NCAC 6F .0005, I certify that the animal waste management system for the farm named
above has an animal waste management plan that rnects or exceeds standards and specifications of the
Division of Environmental Management (DEM) as specified in 15A NCAC 2H.0217 and the USDA -Natural
Resources Conservation Service (MRCS) and/or the North Carolina Soil and Water Conservation
Commission pursuant to 15A NCAC 2H.0217 and 15A NCAC 6F .0001-.0005. The following elements are
included in the plan as applicable. While each category designates a technical specialist who may sign each
certification (SD, SI, WUP, RC, I), the technical specialist should only certify parts for which they are
technically competent.
IL Certification of Design
A) Collection Storage, Treatment System
Check the appropriate box
O Existing facility without retrofit (SD or WUP)
Storage volume is adequate for operation capacity; storage capability consistent with waste utilization
requirements.
❑ New, expanded or retrofitted facility (SD)
Animal waste storage and treatment structures, such as but not limited to collection systems, lagoons and ponds,
have been design:xd to ineet or exceed the minimum standards and specifications.
Name of Technical Specialist (Please Print): Harry S. Tyson
Affiliation: USDA - NRCS
Address (Agency): 604 College St. Jacksonville NC 28540-5392 Phone No.: 910 455-4472
Signature: Date:
B) Land Application eite (WUP)
The plan provides for minimum separations (buffers); adequate amount of land for waste utilization; chosen crop
is suitable for waste management; hydraulic and nutrient loading rates.
Name of Technical Specialist (Please Print):. Harm S. Tyson
Affiliation: USDA - NRCS
Address (Agency): 604 CollEge S . Jacksonville NC 28540-5392 Phone No.: 910 455-4472
Signature: �, Dale:,
C) Runoff Controls iYom Exterior Lots
Check the appropriate box
Et' -facility without exterior lots (SD or WUP or RC)
This facility does not contain any exterior lots.
❑ Facility with exterior lots (RC)
Methods to minimize the run off of pollutants from lounging and heavy use areas have been designed
in accordance with technical standards developed by NRCS.
Nance of Technical Specialist (Please Print): IlarEy S. Tyson
Affiliation: USDA -- NRCS
Address (Agency): 604 College St. Jacksonville, NC 28540-5392 Phone No.:[phone]
Signature: Date: f
AWC -- Januaw 1,199 Z4 2

D) Application and Handling Equipment
Check the apprr,l,riale box
e14
Animal waste application equipment specified in, the plan
accordance with existing design charts and tables and is able
waste management plan: (existing application equipment can
exceed either the specified hydraulic or nutrient loading rate
s
❑ New. cxpandcd. or cxist4ig facility without cxist4ig wastc application equipment for sorav irrigation.
Animal waste application equipment specified in the plan has been designed to apply waste as necessary to
accommodate the waste management plan; (proposed application equipment can cover the area required by the
plan at rates not to exceed either the specified hydraulic or nutrient loading rates; a schedule for timing of
applications has been established; required buffers can be maintained; calibration and adjustment guidance are
contained as part of the plan).
❑ New. expanded. or exist ing_ facil i ty without existing waste application cyuipment for landspreading.
not Using spray irri ag tion. (WUP or 1)
Animal waste application equipment specified in the plan has been selected to apply waste as necessary to
accommodate the waste management plan; (proposed application equipment can cover the area required by the
plan at rates not to exceed either the specified hydraulic or nutrient loading rates; a schedule for timing of
applications has been established; required buffers can be maintained; calibration and adjustment guidance are
contained as part of the plan).
Naive of Technical Specialist (Please Print): Marry S. Tyson
Affiliation: USDA - NRCS
Address (Agency): 604 College St. Jacksonville, NC 28540-5392 Phone No.: [phone]
Signature: Date:
E Odor Control, Ins a Control, Nloltality Management and Emergency Action Plan (SD, SI, WUP,
RC or I
The waste management plan for this facility includes a Waste Management Odor Control Checklist, an Insect
Control Checklist, a Mortality Management Checklist and an Emergency Action Plan. Sources of both odors and
insects have been evaluated with respect to this site and Best Management Practices to Minimize Odors and Best
Management Practices to Control Insects have been selected and included in the waste management plan. Both
the Mortality Management Plan and the Emergency Action Plan are complete and can be implemented by this
facility.
Name of Technical Specialist (Please Print): Harry S. Tyson
Affiliation: USDA - NRCS
Address (Agency): 604 College St. Jacksonville, NC 28540-5392 Phone No.: [phone]
Signature: � �f� � Date:_/Z//8 4-7
F) Written Notice of Ne or Expanding wig ne Farm
The following signalore block is only to Ire used for new or expanding swine farnis that begin construction after .Inne 21.
1996. If the facility was built before June 21,1996, when was it constructed or last expanded
I (we) certify that I (we) have attempted to contact by certified mail all adjoining property owners and all property owners
who own property located across a public road, street, or highway from this new or expanding swine farm. The notice
was in compliance with the requirements of NCGS 106-805. A copy of the notice and a list of the property owners
notified is attached.
Name of Land Owner:
Signature: Date:
Name of Manager (if different from owner):
Signature:
Date:
AWC -- January 1, 1997

III. Certification of Installation
A) Collection, Storage, Treatment Installation
New. cxpanded or retrofitted facility (SI)
Animal waste storage and treatment structures, such as but not limited to lagoons and ponds, have been installed
in accordance with the approved plan to meet or exceed the minimum standards and specifications.
For existing facilities without retrofits, no certification is necessary.
Name of Technical Specialist (Please Print):
AL7`tliatiow.
Address (Agency):
Signature:
B) Land Application Site (WUP)
Check the appropriate hox
Phone No.:
Date:
©" The cropping system is in place on all land as specified in the animal waste management plan.
❑ Conditional Approval: all required land as specified in the plats is cleared for planting: the: cropping
system as specified in the waste utilization plan has not been established and the owner has committed
to establish the vegetation as specified in the plan by _(month/day/year); the proposed
cover crop is appropriate for compliance with the waste utilization plan.
❑ Also check this box if appropriatc
if the cropping system as specified in the plan can not be established on newly cleared land within 30 days of
this certification, the owner has committed to establish an interim crop for erosion control.
Name of Technical Specialist (Please Print): Harry S. Tyson
Affiliation: USDA - NRCS
Address (Agency): 604 College St. Jacksonville NC 28540-5392 Phone No.: [phone]
Signature: _ Date:_ /z
This following signature block is on to be used when the box for conditional approval in III. B above
has been checked.
I (we) certify that I (we) have committed to establish the cropping system as specified in my (our) waste
utilization plan. and if appropriate to establish the interim crop for erosion control, and will submit to DEM a
verification of the completion from a Technical Specialist within 15 calendar days following the date specified
in the conditional certification. I (we) rcali7c that failure to submit this verification is a violation of the waste
management plan and will subject me (us) to an enforcement action from DEM.
Name of Land Owner (Please Print):
Signature:
Name of Manager (if different from owner):
Date:
Signature: Date:
AWC --- January 1, 1997 4

C. Runoff Controls from Exterior Lots (RC)
Facility with exterior lots
Methods to minimize the run off of pollutants from lounging and heavy use areas have been installed as specified
in the plan.
For facilities without exterior lots, no certification is necessary.
Name of Technical Specialist (Please Print): Harty S. Tvson _
Affiliation: USDA - NRCS
Address (Agency): 604 College St. Jacksonville, NC 28540-5392 Phone No.:-C9]0) 455-4472
Signature:_ Date:
D) Application and Handling Equipment Installation (WUP or I)
Check the appropriate block
Animal waste application and handling equipment specified in the plan is on site and ready for use; calibration
and adjustment materials have been provided to the owners and are contained as part of the plan
❑ Animal waste application and handling equipment specified in the plan has not been installed but the owner has
proposed leasing or third party application and has provided a signed contract; equipment specified in the
contract agrees with the requirements of the plan; required buffers can be maintained; calibration and adjustment
guidance have been provided to the owners and are contained as part of the plan.
❑ Conditional Approval: Animal waste application and handling equipment specified in the plan has been
purchased and will be on site and installed by (month/day/year); there is adequate storage to
hold the waste until the equipment is installed and until the waste can be land applied in accordance with the
cropping system contained in the plan; and calibration and adjustment guidance have been provided to the
owners and are contained as part of the plan. �—
Name. of Technical Specialist (Please Print): ;ia r r y S. l y Sa,t1
Affiliation: V 570,6 — /VJRC_' S
Address (Agency): Z49 -5Y, TIE b6,41 Ville. �• Phone No.:
Signature: _ _�. rtoo
Date: l��y:7
The following signs re block is onused when the box for conditional approval in Ill. D above
has been checked.
i (we) certify that l (we) -have committed to purchase the animal waste application and handling equipment as specified in
my (our) waste utilization plan and will submit to DEM a verification of delivery and installation from a Technical
Specialist within 15 calendar days following the date specified in the conditional certification. 1 (we) realize that failure
to submit this verification is a violation of the waste management plan and will subject me (us) to an enforcement action
from DEM.
Name of Land Owner (Please Print):
Signature: Dale:
Name of Manager (if different from owner):
Signature:
Dale:
E) Odor Control, Insect Control and Mortality Management (SD, SI, WUP, RC or I)
Methods to control odors and insects as specified in the Plan have been installed and are operational. The
mortality management system as specified in the Plan has also been installed and is operational.
Name of Technical Specialist (Please Print): I
Affiliation: USDA-NRCS
Address (Agency): 604 Colle e St. Jac;ksonvill
Signature:
AWC— January 1, 1
S. T
.8540-5392 Phone No.: 910) 455-4472
Date: /-
S

UnitedSlntns S�0 Donald A. Halsey Ag: Building
Onverlment of corfservallon 504 College 5tr"�(± �0�
ilWIcullure Service JacksonviIIe,VVNC:P 28b4�D E^?r`C,'V
IOCi .1 t 1-919
October 24, 1991 .
lVan-Discharge Parmrtung
Mr. William Hardy Howard
559 Barbee Road
• Richlands, NC 28574
bear Mr. Howard:
IhIs letter is to review the respnnsibllftles of the golf Conservation
Service and operators in planning, design, construction, and operations and
maintenance of livestock waste management systems.
SCS RESPONSiBiLItIES:
I. lnvn_stlgnte site or sites with owner to evaluate location, solls,
area needed to receive effluent, etc.
2. Survey and design system to meet SCS.and state guides.
• 3. Review design with operator.
h. Construction check and certification.
ONIIER/OI ERATOR RESi'OiISiBILITIES:
1. Locate or agree to location of operation.
2. Review and concur In design hefore construction begins, Including
location of land and area needed to receive effluent.
3. Assure that practices) Is/are constructed as designed.
4. lfalntaln and operate system to meet state standards, Including pumping
all excess effluent on crops and/or pasture that will utilize nutrients
In Affluent. Effluent should be applied at rate and amount to prevent
runoff or leaching.
5. Cnnstruct and operate system so -as to comply with local, state and
federal regulations.
Waste management systems that are not operated and maintained properly
may be In violation of state and federal regulations._
Snne deflciencles In construction and operation that have occurred and,
In some Instances, caused complaints, are:
%t th:4of Con•Pivellnn $prvle•
1s n •goncr or the
Oeperfmon1 of AQrleulluTo

1. Areas around buildings and lagoons not vegetated.
Z. Vegetation not mairttalned by mowing and fertilizing.
3• Waste flowing over lagoon banks,
4. Waste from lagoon flowing through open ditches or pipes Into ditches,
streams, ponds, etc. =
Please contact our office if we can provide assistance with your
waste management system.
Sincerely,
7
r

Unded Slal6s Sg _
Department of Conservation
Agriculture Service
OPERATOR: Hardy_ Howard
Please review the attached plan and specifications carefully. Retain
this plan for your use and records. It is strongly recommended that you,
your contractor, and Soil Conservation Service personnel are in agreement
as to how the waste lagoon is to be constructed. The Soil Conservation
Service personnel will meet with all concerned parties and walk over the
site to explain all flags and markings. It is important that everyone
understand what is expected so that final construction meets plans and
specification and the job can be certified for payment (if cost -sharing
Is involved).
The pad 'dimensions and grades are the best estimate. The BUILDER or
CONTRACTOR is RESPONSIBLE for final layout and design of the pads. The
Soil Conservation Service personnel will assist in a limited capacity,
as Its major concern Is the proper design and construction of the waste
treatment lagoon.
The actual amount of material required for pads and'dam may vary from the
estimates. The design will attempt to balance cuts and fills as close as
possible. If additional material is required after construction is complete
on the lagoon, the contractor and owner will negotiate on the price and
location of borrow area.
NOTE: Design Requirement: Z �7� cu.ft. s ?5' 3/ cu.yds.
Estimate of Excavation: /,FGsy cu.ft. 4cu.yds.
Estimate of Pad s Dike: /4/S 5TY cu.ft. s ��39?_ u.yds.
I.zf: i Ration
Job Class
w &rl f
Da ee
Designed By Z'_�.�-
Name
Design Approval-
Na
!a zS
Da e
e
'L O Tha $aa Cameervalron SerVIG�
is an agency of the
090lrt+nent of Agrtcultwf

SFEClF1CATYONS F[�� CO��TRi/CTlON OF u����� 1�REATMEN7 LA�OUWS
---------
All ti-9R9 and hrosh -hal] be rvmove6 Urnm thrs constroct10n'a0',-s
hPfore eny excavntiI,�j OF fill is starte6. Stumps wi1l be remo,c-6
wi thin the arr?,R of th-, fnu.vj�t ion �f the imbankment and f1ll
and all areiIs. All. stumps. *xnH ronUs excemding cne (l>
incI. in diF-tmeter ---6all tIe remcvr=:cl to s mini*om depth co F ore (1>
frot' Will bP mm6e of All The
foundatinn area be loosened Uhnrough1v before Place(Te-wit nf
em6ankmen I: matertal'
Cut-of-f Trenchx
A cut-�:Iff hrencJI (w|en specified) shoall tic.? i..ste]1md as shnww' in
ths plans.
Eonstructin`,:
Conr;truC'Ai," "f eqc�,o/'�d �`,dearV`fill --we-At; shall o oh�1� b� per�d �
the nc:?t 1i�s nAnd grades a� planv/ed. Deviations from hhts will
reqoirrr or -.' approval nf thn 5CS' E" ;trthfill nhall no bIact-d
in rtan,11ng v�­ter pn'| `'en'ona6le c�mpackion nf the fills sh�ll hc.
perf�:trmri7d by thr eq/'Ipme-It or rn11e1 ch'r\rig
pemha`��ment of the b4-:1 il`stallmd usi`l�
the m�rn tmp�`'vim�= m���ria}s. Cnnstruch�on of fill heights 7,hal1
inclmde ��n (!0) pr settlement. To prnf;ect �gai^sage,
whel I arf u/IT, oi+�ihlCE.? matcm- ial pre encmuntnred, they wi1] nemid t"
h1r,7 n minimvm n[ cnr.- (1) font hmlnv grade and 6ackfilled awl
compact�-d with a soitahYe matari�� (i�-O-�SC,CHy' Refer to t6r, soils
invnntiinfn111,-.ns -Vor special cnn�td�r��inn�.
Pr�ceyti�ns �hoo|d be �aken 6uring cnosh'uc�ion tn prxavVnt r:Cn�sive
�rnsimn end �edifit �`'te"n'
Veget-1ttnn:
All �/�posed en6,ankm�vt e'r� cthcr har�� cc'`�mtr'/cted areas sh�l� hr
c Ied�d �n tho pl�nneJ �ypp, nf veg-tation -As �oon as poss�blp
cm�stti"n.

SEEDING RECOMMENDATIONS
AREA TO BE SEEDED: Ad ACRES
USE THE SEED MIXTUOE INDICATED:
G U LBS. FESCUE GRASS D 60 LBS./ACRE
(BEST SUITED ❑N CLAYEY OR WET SOIL CONDITIONS)
SEEDING DATES: SEPTEMBER 15 TO NOVEMBER 30
LBS. 'PENSACOLA' BAHIA GRASS a 60 LBS./ACRE
(SEE FOOTNOTE NO. -1)
SEEDING DATES: MARCH 15 TO JUNE 30
LBS. HULLED BERMUDA GRASS @ B LBS./AC.
(SUITED FOR MOST SOIL CONDITIONS)
SEEDING DATES: APRIL 1 TO JULY 31
LBS. RYE GRAIN a 30 LBS:/ACRE (NURSERY FOR FESCUE)
LBS. RYE GRASS @ 40 LBS./ACRE (TEMPORARY VEGETATION)
SEEDING DATES: DECEMBER 1 TO MARCH 30
LBS.
APPLY THE FOLLOWING:
/400 LBS. OF 10-10--10 FERTILIZER (1000 LBS./ACRE)
7--TONS OF DOLOMITIC LIME (2 TONS/ACRE)
�QD _BALES OF SMALL GRAIN STRAW (100 BALES/ACRE)
ALL SURFACE DRAINS SHOULD BE INSTALLED PRIOR TO SEEDING. SHAPE
ALL DISTURBED AREA IMMEDIATELY AFTER EARTH MOVING IS COMPLETED.
APPLY LIME AND FERTILIZER THEN DISK TO PREPARE A 3 TO 4 INCH
SMOOTH SEEDBED. APPLY SEED AND FIRM SEEDBED WITH A CULTIPACKER
OR SIMILAR EQUIPMENT. APPLY MULCH AND SECURE WITH A MULCH
ANCHORING TOOL OR NETTING.
1. PENSACOLA BAHIAGRASS IS SLOWER TO ESTABLISH THAN COMMON
BERMUDA GRASS. WHEN USING BAHIA, IT IS RECOMMENDED THAT 8
LBS./ACRE OF COMMON BERMUDA BE INCLUDED TO PROVIDE COVER
UNTIL BAHIAGRASS IS ESTABLISHED.

OPERATION AND MAINTENANCE PLAN'
_Hardy HoWard
This lagoon is designed for waste treatment with minimum odor control.
The time required for the planned fluid level to be reached may vary due to
soil conditions, flushing operations, and with no fresh water added to the
system. Plans are to recycle waste water in the flushing operation.
Land application of waste water is recognized as an acceptable method of
disposal. Methods of application include honey wagons (sprayer or injection)
for small operations and irrigation (center pivot, guns, or travelers). Care
needs to be taken when applying waste to prevent damage to'crops or -runoff
from the field.
The following -items are to be.carried out:
I. Begin pump -out of the lagoon when fluid level reaches invert of outlet
pipes. Elev. 52.8'
2. Stop pump -out before fluid depth is less than 6 feet deep (this prevents
the loss of favorable bacteria). Elev. 50.5'
3. The recommended maximum amount to apply per irrigation is one inch, and
maximum recommended application rate is 0.4 inch per hour.
4. It is strongly recommended that the treatment lagoon be precharged to
112 its capacity to prevent excessive odors during startup. Precharging
reduces the concentration of the initial waste entering the lagoon thereby
reducing odors. Solids should be covered with effluent at all times.
5. Keep vegetation on,the embankment and areas adjacent to the lagoon mowed.
6. Repair any eroded areas and establish in vegetation.
7. The Clean Water Act of 1977 prohibits the discharge of pollutants into
waters of the United States. The Department of Natural Resources and Community
Development (DNRCD), Wastewater Management Section, has the responsibility
for enforcing this law.
8. All surface runoff is to be diverted from the lagoon to adequate outlets.
CERTIFICATION:
I hereby certify that I understand the operation and maintenance requirements
stated above. Furthermore, I understand how many acres are required in order
to land apply the waste and that the lagoon may have to be pumped 2 or more
times a year. This design has been explained to me and I agree with all
provisions stated in the design. I also certify that there are no residence
other than mine or my tenants' within 750 feet of this operation. I
understand that compliance with this design DOES NOT prevent someone from
suing me because of nuisance or other reasons.
Signature Date /Q �,teyz

A7TACIllfF.M' A
r:
f'ntt^ 7
_I z�Y_animal^ x Z,_3__lb_s U/animal/yr, -_TZ 7/0' Ion total !I
Applying the abov, amount of warm, to a bi.'l job. You should
plats time and haves npor.opriatq qqq i.prnent_ to 'npoly' the wa ,tn in
timely manner:. Your facility is Orni.gnnd for _1�� dayn of
ntorage. Therefore/ it will need to be pnmpAd every
months.
The fol.lo Ng acrnngfi for waste appl #-ration will• be needed
based on the crop to hi grown and surface application:
fi.ld "toll lsav 00'.11itIr• 11.*, v Arr►• It". It H—tth of
" Iyr TI►Id I'er Ac. /i�'�r"^` ' •� Utflfzed Arpllcr+tloci
/1'i Ar_fer
Narrative of operation
'sO.P _ Z 2 `/ _ �n.JJ_h+c T6GnF� • 7�' f ni, tN _�i0f�f�raW ._
__�J LPN,. C�f _�L�Nf r! _ /"HMr E_FflV14�.V %ONT(J µ CQ/�LANO ra rC t:De.�eG Gv�+.r�cRe�pL
FE,r Pt_ize,Q_ (hours
Call. the Sail and Water Corrservatto" District Office after you
waste analysis report to obtain the amount per acre to
apply and the irrigation application rate prior to applying
wastr_ .
Prr'lllr-nr t -�? L/ /
. � � >D�z f 9
tlalnn Tit Le Uat.-
1
Ald
F'rn�iltrer_ DatA
(r•.r.y to 1.r.,,k, .r ai.I cf-ry tfi rn.. fn,e)
Y

ATTACIMC11T A
Page L
1111 ;TF: UT L LI ZAT 1011 f 1,A11
onslow
11ddrPss_ 5 &.Barbee Road _... _ Kind of operation Swine feeder to finish
Richlands,_ NC _28574____.____ 'type of Waste Facility lagoon TM
Your animal waste management facility has been designed for a
given storage capaciy . When the waste reaches the designed
.level, it must be land applied at a specified rate to prevent
pollution of surface and/or ground water. The plant nutrients
in the animal waste should be used to reduce the amount of
commercial fertilizer required for the crops on the fields
where the waste is to be applied. This waste utilization plan
uses nitrogen As the limiting nutrient: Waste should be
analyzed before each application cycle and annual soil tests
are encouraged so that all plant nutrients can be balanced for
realistic yields of the crop to be grown.i
Several factors are important in implementing your waste
utilization plan .in order to maximize the fertilizer value of
the waste and to ensure that it .is applied in an
environmentally safe manner. Always apply waste based on the
named, of the crop to be grown and the nutrient content of the
waste. Do not apply more nitrogen than the crop can utilize.
Soil types are important as they have different infiltration
rates and leaching potental. Waste shall not be applied to
land eroding at greater than 5 tons per acre per year. Do not
apply waste on saturated soils or on land when the surface is
frozen. Either of these conditions may result in runoff to
surface waters. Wind conditions should also be considered to
avoid drift and downwind odor problems. To maximize the value
of nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or
not more than 30 days prior to planting. Injecting the waste
or disking will conserve nutrients and reduce odor problems.
The acres neednd to apply the animal waste is based on typical
nutrient content for this type of .facility. Acreage
requirements may he morn or less based on the waste analysis
report from your waste management facility.
The design of yQur- wi ;te management r:acil ity is based on the
fntlowinq:
i1m.ntttit of t�_ st.P._F'r�citiced _Pe,p Year
J� Z'Lanima.ls x_ �. 9TaNyvr;a�;te /:.animal/yr --_2,3 Z6 r—:total waste
prMuced .

Animal waste lagoons are designed with permanent storage
(waste treatment volume) and temporary storage.
The designed 6 month temporary storage is an estimated
volume based on: 1) waste from animals, 2) excess rainfall
after evaporation; and 3) the largest 24 hour (one day)
rainfall that occurs on the average of once every 25 years.
The volume of waste generated from a given number of animals
will be fairly constant throughout the year and from year to
year. The excess rainfall will vary greatly during the year
and from year to year. This estimate is based on 7 inches
of excess rainfall which is equal to or exceeds the highest
6 months excess in a year. The average annual excess
rainfall is approximately 8 inches. Therefore, an average
of 8 inches of excess rainfall will need to be pumped each
year. The 25 year rainfall will not be a factor to consider
in an annual pumping cycle, but this storage volume moist
always be available. A maximum elevation is determined in
each design to begin pumping and this is usually the outlet
invert of pipe from building(s). If the outlet pipe is not
installed on the elevation to begin pumping, a permanent
marker must be installed on this elevation to indicate when
pumping should begin. After initial filling of lagoon, a
minimum 6 feet depth must be maintained for anerobic
treatment of waste. An elevation must be established to
stop pumping to maintain the minimum treatment depth.
Fumping can be started or stopped anytime between these two
elevations for operating convenience so long as site
conditions permit (conditions are weather, soil, crop, and
equipment to apply waste to prevent runoff or leaching).
For thi.s lagoon the maximum elevation to begin pumping is
5Z,S'feet and the minimum elevation to pump to is feet.
The design temporary storage, less 25 year storm, is4/So3
cubic feet orYFL'7Z gallons. As stated before, this volume
will vary considerably from year to year.
This lagoon is designed to flush buildings with recycled
lagoon liquid, and fresh water should not be used for
flushing after initial filling.

--ark r:'�• w -n- 1' �, ` 3r `( i. - •!.•�`
. . . . . . . . . .
�' �'`.. : � " �' ' � ztw i• , � ,' •` des • I .,i �' i,
Vi
• •� >: . - --. 7-�, ,,>.�:, pci.l'�] _ sin• � q)�,:� 1 ^`��
CIL
v i C04
/`Oro j. '.�r�� , � � �•.f� r \1 ����,l��r�� 1
zr IN
17
TIAPA
°._.� �4 � � t ', a "'• �s, �'� ��
t Z ji � t f. r. 5;• y.-•
� i'� `y 2 F � t ' t •Yx•j��.
- : �-4r'f' �� -_ iI � �. ¢ � �. '.Y;,�`� • � F�+��•� =' 5�? } �.6 �' .r�:>j s1)r�t w5 ,'..
�`w4ff,'^=- S �\J+f � "•L'.� - T:,.► ..lPPy.. a •rsr" 7 � ��
t
F{ 1 C f �� ..��Ecccc i�� .�' y ,��Ft '� ,�•I.F, .� 7`�� � 1�i. -4C•.
Y ` j (; :7.:: ; .�� i .h it r ! �• .�; 't ,.fit 1f` 7� €� f ! a11' _�+,�s'� y'�,
-r +t, '+!
s
30
_tipp �� � .•a:" � � �iK�,�.�'•.".,,� .� ,�� ,= s .i�i.+ .�j `,•!�..Lti. ..�+i f .�'
_ }��k�1 ►� ' b•ti Y s ,�, ��F Q s:74
yy,, t ti . � Y=1 � iit`��,.i• j.- s-t%� .` r i t,��+t�`:,{ •/•'`io .,fir
•*5- 17` .ram-� .w.H "'�1F'` 16 m �` mod` .i.:d'j. - •?'!4 ,.
it y� Ln
►.Snl
'� - r ��s��1 .i 4t1� :l'-•� •�'TSrT.y1rR���-r,•i�, �i'�t •'1,FS•t''r�, �a '� „� +-;'^
GIV
} ;' t
to •,:.�^ % 'ram r -

let,
it
Awl
.. J.O*,
4 Fj
-77
VN ,
-Alo
V-T
w

Agri -Waste Management
Biological and Agricultural Engineering North Carolina State University
LIVESTOCK WASTE SAMPLING, ANALYSIS AND CALCULATION
OF LAND APPLICATION RATES
James C. Barker*
I. SAMPLE COLLECTION
A. Semi -Solid Lot Manure
i. Scraped directly from lot into spreader
a. From loaded spreader, collect about 2 lbs of manure from
different locations using nonmetallic collectors,
ii. From storage
a. Collect about 2 Lbs of manure from under the surface crust
r avoiding bedding materials and using nonmetallic collectors.
B. Liquid Manure Slurry
1
i. Under -slotted -floor pit
a. Extend a 1/2" nonmetallic conduit open on both ends into
manure to pit floor.
b. Seal upper end. of conduit (e.g., by placing a thumb over end
r of conduit) trapping manure that has entered lower end, remove
E and empty slurry into plastic bucket or nonmetallic container,
c, Take subsamples from 5 or more locations or at least 1 quart,
d. Nix andladd about 3/4 pint to nonmetallic sample container.
ii. Exterior storage basin or tank
a. Hake sure manure has been -ell mixed with a liquid manure
chopper -agitator pump or propeller agitator.
b. Take subsamples from about S pit locations, from agitator pump
or,from manure spreader and place in a plastic bucket.
* Professor and Extension Specialist, Biological and Agricultural Engineering
Department, North CarolinA State University, Raleigh, HC.

A-r-r OC t
MW
c. Mix and add 3/4 pint to a nonmetallic sample container.
C. Lagoon Liquid
1. Collect about 3/4 pint of recycled lagoon liquid from inflow pipe
to flush tanks in a nonmetallic sample container.
it. From lagoon
a. Place a small bottle (1/2 pint or less) on end of 10.15' pole.
b. Extend bottle 10-15' away from bank edge.
c. Brush away floating scum or debris.
d. Submerge bottle within 1' of liquid surface.
e. Empty into a plastic bucket, repeat about 5 times around
lagoon. mix, and add 3/4 pint to nonmetallic sample container.
D. Broiler or Turkey Litter
1. House litter
a. Visually inspect litter for areas of varying quality, e.g.,
areas around feeders and waterers. and estimate percent of
floor surface in each area.
b. Take about 5 litter subsamples at locations proportionate to
item a. E.g., if 204 of litter of similar visual quality is
around feeders and waterers, take 1 subsample there and the
other 4 subsamples from remainder of floor surface.
c. At each location, collect litter from a 6" by 6" area down to
earth floor ano place in a plastic bucket.
d. After 5 subspm�les-have been added to the bucket, mix, and add
about-2-3 lbs litter to a nonmetallic sample container such as
a 1-gallon freezer bag and seal.
C it. From stockpile
a. Take suisamples from about 5 locations at least 18" into pile.
I
b. Mix, add 2-3 lbs to nonmetallic sample container and seal.
f

r
A -T t AcA m c" -t f3
3
II. SAMPLE PREPARATION AND TRANSFER
.. Place sample into an expandable container that can be sealed. Rinse
residues from container with clean water but do not use disinfectants,
soaps, or treat in any other way.
B. Pack sample in ice, refrigerate, freeze, or transfer to lab quickly.
C. Hand -delivery is most reliable Way of sample transfer.
D. If mailed, protect sample container with packing material such as
newspaper, box or package with wrapping paper, and tape.
E. Commercial sample containers and mailers are also available. Contacts:
I. A& L Eastern Agricultural Lab. Inc. III. Polyfoam Packers Corp.
7621 Vhltepine Road 2320 S. Foster Avenue
Richmond, VA '23237 Vheeling. It. 60090
Ph: [phone] Ph: [phone]
It. Fisher Scientific Co. iv. NASCO
3315 Winton Road 901 Janesville Avenue
Raleigh, NC 27604 Fort Atkinson, WI 53538
Ph: [phone] Ph: [phone]
F. Private analytical labs are available, but sample analyses are costly.
G. The NCDA provides this service for North Carolina residents.
I. Address: -North Carolina Department of Agriculture
4 Agronomic Division
Plant/Waste/Solution Advisory Section
Blue Ridge Road'Center
P.O. Box 27647
1 Raleigh, NC 21611
Ph: [phone]
f Attn: Tr. Ray Campbell
ii. Forward $4 along vith'the sample.
I
Ill. Include the following identification information with sample:
i .
' a. Livestock species (dairy. swine. turkey. etc.)
b, Livestock usage (swine -nursery, finishing; turkey -breeders,
brooderhouse, grower. number flocks grown on litter; etc.)
c. Waste type (dairy -lot scraped manure, liquid slurry; swine -pit
slurry, lagoon liquid, sludge; broiler -house litter, stockpile
iv. Routine analyses performed on all samples: N. P. K, Ca, Mg. Na,
s S, Fe, Hn, Zn, Cu, 8
v. Additional analyses performed upon request: DM, Ho, Cd. Ni. Pb

U. S. Department of Agriculture NC-ENG-34
Soil Conservation Service September 1980
File Code: 210
HAZARD CLASSIFICATION DATA SHEET FOR DAMS
Landowner Hardy Howard _ County Onslow
Community or Group No. Conservation Plan No.
Estimated Depth of Water to Top -of Dam Ft. Length of Flood Pool z 5�a Ft.
Date of Field Hazard Investigation
Evaluation by reach of flood plain downstream to the point of estimated minor effect
from sudden dam failure.
Est. Elev. :Est eva on
Kind of :Improvements: of Breach
Reach: Length: Width: Slope: Land Use Improvements Above :Floodwater Above
Flood Plain: Flood Plain
t. Ft. t. Ft.
1
2
Describe potential
for loss of life and damage
to existing or
probable future downstream
improvements from a
sudden breach A
CNOjq&r'rl
I/I E oR /9"19c.e
7t4Vf10110,ST117'f0r� faci�ir�r_
Gi>Gao.� ara
co AR.w,rJ trots de nD
Lsr ooN
Hazard Classification of -Dam (V b, c) (see NEM-Part 520.21)
L n aaa,;
4)m Classification (I, II, III, IV, V)_
By—' name
e
Concurred By 4•
nam tit e I —
NOTE: 1. Instructions on reverse side.
2. Attach additional sheets as needed.
Date /D0z /7
Date Y G Z ,g /
5 d�

INSTRUCTIONS
All dams built with technical assistance from the Soil Conservation Service
must have a hazard classification assigned by the person responsible for
approving the design. Most farm ponds,texcept in borderline cases, can
be classified after a complete field investigation without assuming failure
and making breach studies. This data sheet is to be used for recording
the information obtained through field studies and for documenting the
hazard classification. Where there is a possibility for loss of life or
major property damage from a dam failure, an approved breach routing
procedure is to be used. (Consult with the area engineer.)
Hazard classifications of Aams are -made by evaluating the possibility
for loss of life and the eftent of damage that would result if the dam
should suddenly breach --that is --a section of the dam be suddenly and
completely washed out. It is to be assumed that a wall of water will be
released equal to the height of the dam. This flood wave will be reduced
in height as it moves down the flood Main. The wave height (depth of
flooding) should be evaluated for a sufficient distance downstream until
the estimated flood level will not cause significant damage to improvements,
such as homes, buildings, roads, utilities, reservoirs', etc. The breach
flood level will be reduced depending on the valley storage, slope, and
openers of the flood plain; however, in a narrow steep valley slopes
steeper than 10% should be given special consideration. One method of
evaluation is to compare available valley storage (under flood conditions)
to impoundment storage (figured to the top of the dam) for each reach
evaluated with a judgment estimate made of the flood wave height -at all
critical points downstream.
Should there be any questions about the hazard classification for a dam,
the area engineer should be consulted before making design commitments.
s

SUS-tNG-538 - U. g, OEPARIMENT OF AGRICULTURE
Rev. 5-70 _� SOIL CONSERVAlloN SERVI6E
SOIL INVESTIGATION TO DETERMINE SUITARILITY nF PROPngFn Porm S1TF
FARMER'S NAME441-4 r x* DISTRICT—
DATE-
S. C. S. PHOTO SHEET NO. WORK [MIT. .� 4rseN�ru�
WATERSHED AREA MEASUREMENTS
CROPLAND ACRES PASTURE ACRES
WOODLAND ACRES TOTAL ACRES POND CLASS WORK UNIT CONSERVATIONIST
SKETCH OF PROPOSED POND STIOWING WHERE, 13ORINGS WERE MADE (Approx. scale 1"= feet)
Locate reference Paint in center fine of dare and identify an sketch.
1
SHOW
DEPTH
SCA T ^
136RING NUMBER AND PROFILE
Make and list darn sffc and spillway borings first - then panded area and borrow s,ft borings -separate with vertfcat red fine.
nfi ,,d "n bark u-hrry nece-ssary) Show water table elevations an dam -site borings.
• !
—
1
S i
2
fi�
3
4
5
—
6
—
7
S.
9
—
—
10
11
12
13
14
15
16
17
18
19
20
21
'22
23
f/!1
—
Z.3
3 - �
f
f
5 in
f- f-
5t [L
G -'7
sell
rz
Kct
% 8
`9
CLSC
CLL!
_G,CN
BORINGS MADE BYJL�-srs+J _ SIGNATURE & TM l✓ Q •+e.
,t S,r'ji6 igj- 1-/IGM 1,MR7fe 7A'4if-

TYPES OF MATERIAL ENCOUNTERED IN BORINGS
(Use one of systems below)
UNIFIED CLASSIFICATION
GW-Well graded gravels; gravel, sand mix
GP - Poorly graded gravels
GM -Silty gravels; gravel -sand -silt mix
GC -Clayey gravels; gravel -sand -clay mix
SW -Well graded sands; sand -grovel mix
SP - Poorly graded sands
SM-Silty sand
SC -Clayey sands; sand -clay mixtures
ML- Silts; silty, v. fine sands; sandy or clayey silt
CL-Clays of low to meditrm plasticity
CII-inorganic clays of high plasticity
Mll-Elastic silts
OL - Organic silts and silty clays, low plasticity
OH -Organic clays, medium to high plasticity
USDA CLASSIFICATION
g-gravel
s - sand
vfs- very fine sand
sl-sandy loam
isl - Fine sandy loam .
I - loam
gl- gravelly loam
si-silt
sil-silt loam
cl- clay loam
sicl-silty clay loam
scl-sandy clay loam
sic -silty clay
c -clay
1. Suitable material for embankment in available Yes No (Indicate wdtre located on th► skttch on
reverse side
REMARKS:
I Explain hazards requiring special attention in design (Seeyave, syrtnv.•roc* etc)
GENERAL REMARKS:
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
60
51

-7-
:7-
M7
--PP e03 F D.:
7-
......
7­1
z
F
7­1
H44—
. . . . . . . . .
.......
r
-T
UdbalrD —I
7
............
k=3
jai
a.H
LIE i
--T
HARDY 1�40WAP_ D
ANIMAi- WASTE 'HG-f.
+�L
+
Ux
TA wad
_;�- +
_1-44-
'T
U. S. DEPARTMENT
ma CONSERVATION
OF AGRICULTURE;
SERVICE
H.
............................ .
.. ..................... ..
... .......
---------- .........
J
SCS-ENG 315A REV 8.75

_. _
�- ------------.4_'-�-_�_..=.{-----�....�_
��
•--�.......------_._.C-.___—._�r..:;:1,Z2!•[_.-��EFDF��_TO:-�-F1F(�SN�._
- ---i-"St�RA:GL-:-}--- ---_----;----•---_�:::.».__...-._,.�` - .._._.._.
-• _...►.N..n� -{
KAG�-'-Av t•Abw -
'
_"
i.w
1.
t4-1
-
7_=
m
i T i
-� —T -r
=-i i�
Yi
" T'' . 1I
I F.1 I—
r
j�2TGPOE
ailigu=
-'1•iFR�Ki&1]�4t5�N��'�1
� �ZTLSA+G�•'��-.__.
'--.1••r-
a
-�-?1-;-.ir-'"::.,.`Z`...^;�.
AGN'f_.-hF^-yiTc.+t
_r ��,
•'{.':_`'
-
-'-'"-'-' ���'�:-
�•_�...�
_•-
. , ,
-
-:-�-=*--r
-mot
- -+-- �k1
• � ,
=�ilCJ�fIK'flD
`�_..-.-}-;-L+
Q �.�.a..
�-�-;-?-}-a-4-,--�
Y`�
--i~r
-r; —
NDWAIZ9
ANIMAL. WASTE MGf
'HARDY
U. S. DEPARTMENT OF AGRiCULTUI
SOIL CONSERVATION SERVICE
1 - _
__}{-
_{:may
M
J t
�_
_:
_ _
-
w w-......._.. --_ • - •-
w-----............
-------- ------
---------- ---------
HET
�
I
SCS-ENG 3;sA R£V f

b . ..... .........
i rw..
Y r
-
-
-:
- t t
-
...--.b
----------------
-•-.--.—--�-
�--^
I
'
�.q
T.-.,__.._.-""fir•.
'-�,`"�-T_
............. •y -
- -
.-_LT,-r'!"-1
.'_'__I"�_t
t—
HDIAIMS NOLL`dAUSSNOD 1109, f�`}l
•S •i
nL'I11Dragym ,INaK1uvdaG V
15W AySVM 'IVW I N Y
��-I
j-
-_
--�r�-•-�--�-
'-�-+----�
� _,..._....
-r"
_
-
y1:;�I:,:��r..i
. ;
'..,_sue-:-•
_•___+_�__-•_.-;
+.•r;y-;-;-
�^-��
-
t
PEE-,
ET
—•—•' —
— —
1'_i—•_. s
....�—.
_•
y�—` {""
-.r.,-�_
YiJ +
�
��
��..w.�—'~1
J,_1—� '�1'
��—.mow....—
— —
! .--�-�-{__"
T'^-'•-
—
,�
.-.�.-.
_
_— .-.—
..»,.�......-1—
-
A ILK
+w.��
yam, .�
_ _
r—_._�_._
��_
JIB
�'.-1
_�_...«.
•—f—�.[_..»—...—_
_

91-9 A3w ME OKISOS
I
r■w1ggwiq/qww■q
qq■q■■■
it
+ � �
q
wrw
��■r■uaa=
w
w
�wr■ur■r■■rs�s■rwwEw■grwwr■www■ma
:qq�s■Rnw�w■
MMUMMWM
t
%
■
■iq■■■gq�isw■�a■iir�we
qs■■rrw■w■r�e■rRw■■wwww=wr'exw■■■■rw
:q�ii■NwwNrwi�w��wr�
_
w�
�;=��wrw
lau�■■w'�awq■■■■s■■frqq■��
■■■qa
mowni=■■�wrwisr`rw��wewwwswwMwwr=iwww`
w■■wrwwwr■www■www■wwwwwIew■wwrtr
�q
�■pr■rq■w�lrwu
�
11wwMiq
rswwwwgi�■�rrr.rr.w�R.�regr.r..rgr.
',
■gwrgaMrrwwrwaowaaowwirwawrwrrwrrsr�+
■■■�%,1�
■su�MW
saww
r
rw■ ■■�
w■
q
■m■ws�w■■rariwgwwgw■■ww�
qq■■■q.
■q■gglw■wwwMwww�r
e�
■q■gggw■q�
am
gwr.ggasqawrwwwr
�
Irt
_
w■
■
q
an
wwgrswirwgwrr
wswgNr■w
�www■■gg■
q
Mm�'
��M■■rq�.
jE
m
q�wwwgq
gruq■gwwuqw■w■q=�
r�rr�
�.
r■rrrrrwwwiwr�r�rr=====rromrrrmw
qtq■�
rwywuwwwq
qr�t "q�■■■ama»sw■�
ww■■■■wma~■■q■www■am■gwaw■wra■■■
�
��rwa■g■g■
rrwrraw�wp�
llei
sew
■■�
tp
w�
wgmgcr:
w �
wraummrgw■wswwr',
■q■■■■s■s■wm
�
,
w
q qq
■qf
q
w
s
w7aw�lwww
_� �
i■■w■■
®
l�
■■A■�
■
owwr®
1

51•9 A3bl VSl[ ON3SOS
r
■
■
!
■
'
r
gss�a�ss
�+ I 1 NIO
i
r �
■
i
f i 0 I. f
:g�aMggg
RMM*M■aiM�ar
-
M�gR�sarq
��
PPON
■rmirMiMMENOWNMqoWEEMS
.rsr..,r...��rrYes■gggassqq■
M■■irY■s!gR■MlrRgMqMrM�■MRMgMMqMM
MRMMMwas
RqMRrqg
mi■�r■A
moms
■
�R�rMR!■M■■i
me
gqgdppqMMq■
�Mq■��R;q
RE
qq
oemum
RgRqg
■r■
��
���'•
g■qqRYq
.5
am
qqrqqqqu
,
m
al
MMMr■Rs■RRRgRMMRlMRMp
w"
qr■q�
■
R�'
■
i!
�RRM�M��NgR!
RggRSRRMMMMMMRMMRMiqMRpMMR
lMMMMMRM■s
gMM■M
RgRq
�IspMs��■Mosm�isiRM�r�rr�
HamMiMMgRN
q
�lMM�MMgM��M�q
isgM�!
im
RMRMMMMMMM
MMURM
WIMMUM
gMN1■RRq■gi■R■
MMMMM
MMq
�RRM=mggMR�MM�MMR�
MMRM_grrrrRRq�R
M■■■RMRMSNwMMRRM■lMp
RARRMq■fgltfRr
MRMRMEN"
MMMRM■gMRMMMMMR0
l
j
MRR�MRM�MMq�M
gMRMRglMp
RMMMMlMMRMMRMMMMMMMMiRggMRq
III I I I I 1 11 loll
i039
MUMMUMMUSE
MRMf
�;
MggM
�MM�
qiM�
�'
gRMRR
R�ppt�rMMSMgR1arMMlgImIRIMqMq
ggMMgq
NMMwgMlRRMq�
i■■glgMe
Me
�q
r

State of North Carolina
Department of Environment,
Health and Natural Resources
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
November 13, 1996
William Howard
Shelby Farm
569 Barbee Rd
Richlands NC 28574
SUBJECT: Operator In Charge Designation
Facility: Shelby Farm
Facility ID#: 67-48
Onslow County
Dear Mr. Howard:
IVA
UEHNR
Senate Bill 1217, An Act to Implement Recommendations of the Blue Ribbon Study
Commission on Agricultural Waste, enacted by the 1996 North Carolina General Assembly,
requires a certified operator for each animal waste management system that serves 250 or more
swine by January 1, 1997. The owner of each animal waste management system must submit a
designation form to the Technical Assistance and Certification Group which designates an
Operator in Charge and is countersigned by the certified operator. The enclosed form must be
submitted by January 1, 1997 for all facilities in operation as of that date. Failure to designate a
certified operator for your animal waste management system is a violation of 15A NCAC 2H
.0224 and may result in the assessment of a civil penalty.
If you have questions concerning operator training or examinations for certification, please
contact your local North Carolina Cooperative Extension Service agent or our office.
Examinations have been offered on an on -going basis in many counties throughout the state for
the past several months and will continue to be offered through December 31, 1996.
Thank you for your cooperation. If you have any questions concerning this requirement please
call Beth Buffington or Bang Huneycutt of our staff at 919n33-0026.
Sincerely,
A. Preston Howard, L..,ector
Division of Water Quality
Enclosure
cc: Wilmington Regional Office
Water Quality Files
P.O. Box 27687, �W�CRaleigh. North Carolina 27611 7687 An Equal Opportunity/Affirmative Action Employer
Voice 919-715-4100 ; � 50% recycled/ lfr°,, post -consumer paper

NOV 1993
Department of Environment, l Health and Natural Resource�r C2i3:,!_ITY
Division of Environmental Management ��� ;PIanninc
Water Quality Section c�r-"_
If the animal waste management system for your feedlot ope` b
is designed to serve more than -or equal to 100 head of cattle, 75
horses, 250 swine, 1,000 sheep, or 30,000 birds that are served
by a liquid waste system, then this form must be filled out and
mailed by December 31, 1993 pursuant to 15A NCAC 2H.0217 (c) in
order to be deemed permitted by DEM. Please print clearly.
Farm Name: Shelby Farm
569 Barbee Road
Richlands, NC 28574
Onslow County
j� /1
Owner (s) Name: 111h
Manager(s) Name: SAIY
Lessee Name:
919-324-4488(H)
Farm Location (Be as specific a ssible: oay3 names, Q
direction, p)ilepost, etc.)*. �L{,��L� �No /{i; fl�?F�/t�
Latitude/Longitude if known: QBSP # 24-006-11-18
Design capacity of animal waste management system�T e� and
type of confined animal(s): r e
Average animal population on the farm (Nu gr
animal(s) raised): �0�2� �� ,(p i e
Year Production Began:
Type of Waste Manag
type of
ASCS Tract No.:
t Sy2tem us a: � A1A�� 6ZiC lR�h/,
FClITI LPLUM*
� 7 6. t T
Acres Available for Land Application of Waste: 1 AULI i
Owner(s) Signature(s): Dater
Date:
( ^ (Anthony Sanderson, Serviceman)

State of North Carolina
Department of Environment,
Health and Natural Resources
Division of Environmental Management
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
A. Preston Howard, Jr., P.E., Director
November 17, 1993
William Howard
569 Barbee Rd.
Richlands NC 28574
Dear Mr. Howard:
AYIPFA
4
C)EHNFR
This is to inform you that you completed registration form required by the recently
modified nondischarge rule has been received by the Division of Environmental Management
(DEW, Water Quality Section.
On December 10, 1992 the Environmental Management Commission adopted a water
quality rule which governs animal waste management systems. The goal of the rule is for
animal operations to be managed such that animal waste is not discharged to surface waters
of the state. The rule allows animal waste systems to be "deemed permitted" if certain
minimum criteria are met (15A NCAC 2H .0217). By submitting this registration you have
met one of the criteria for being deemed permitted.
We would like to remind you that existing feedlots which.meet the size thresholds
listed in the rule, and any new or expanded feedlots constructed between February 1, 1993
and December 31, 1993 must submit a signed certification form to DEM by December 31,
1997. New or expanded feedlots constructed after December 31, 1993 must obtain signed
certification before animals are stocked on the farm. Certification of an approved animal
waste management plan•can be obtained after the Soil and Water Conservation Commission
adopts rules later this year.
We appreciate you providing us with this information. If you have any question about
the new nondischarge rule, please contact David Harding at [phone].
c Sincerely,
Steve Tedder, Chief
J" Water Quality Section
P.O. Sox 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper