670034_HISTORICAL_20171231

NUH I H UAHULINA
Department of Environmental Qual

e 14;
WASTE UTILIZATION PLAN
PRODUCER: aneil Curganvs
171 Fuhimil Rd.
LOCATION: Richlands, NC 28574
TELEPHONE: 91 D 324-2645 4
TYPE OPERATION: Finishing�I
D
NUMBER OF ANIMALS: 2448 APR 9 ,2 2009
t 1
The waste from your animal facility must be land applied at a specified rate to prevent po u 1
of surface and/or groundwater. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops in the fields where the waste is
to be applied. This waste utilization plan uses nitrogen as the fruiting nutrient. Waste should be
analyzed before each application cycle. Annual soil tests are strongly encouraged so that all
plant nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and available water Bolding capacities. Normally waste shall not be applied to land
eroding at greater than 5 tons per acre per year. With special precautions, waste may be
applied to land eroding at up to 10 tons per year. Do not apply waste on saturated soils, when it
is raining, or when the surface is frozen. Either of these conditions may result in runoff to
surface waters which is not aftowwed under DELI regulation_ Wind conditions should also be
considered to avoid drift and downwind odor problems.. To maximize the value of nutrients for
crop production and to reduce the potential for pollution, the waste should be applied to a
growing crop or applied to bare ground not more than 30 days prior to planting. Injecting the
waste or disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for analysis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H.0217 adopted by the Environmental Management Commission.
Page 1
RECEIVED 1 DE:NR / DWO
A0l)IFFP'PPnTFrT10N sFCTl0N
MAR 2 7 2009

WASTE UTILIZATION PLAN
Amount of Waste Produced Per Year fgWllorts. fL Notts, etc.
2,448 animals X 1.9 (tons) waste/animallyear =
Amount of Plant Available Nitrogen (PAN) Produced Per Year
2,448 animals X 2.3 lbs. PAN/animal/year =
Guide Std. 633)
4,651 (tons) waste/year.
5,630 lbs. PAN/year. (PAN from N.C.
Tech
Applying the above amount of waste is a big job. You should Plan time and have appropriate
equipment to apply the waste in a timely manner
The following acreage will be needed for waste application based on the crop to be grown and
surface application.
Table 1: ACRES OWNED BY PRODUCER
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
# No. Twe Per Acre Utilized Application
T317
1 V
GoA
Bermuda H
400
12:47
4988
March - Oct
T317
6
GoA
Bermuda H
400
0.93
372
March - Oct
T317
7
Ln
Bermuda H
200
2.56
512
March - Oct
** OPTIONAL**
1.2.6.7
Small Grain
50
15.96
798
Sept - April
l otal I 15.951 5A72.0U I
*This N is from animal waste only. if nutrients from other sources such as commercial fertilizer are
applied, they must be accounted for. N must be based on realistic yield expectation.
NOTE. The applicator is cautioned that P and K may be over applied while meeting the N
requirements. Beginning in 1996 the Coastal Zone Management Act will require farmers in some
eastern counties of North Caroline to have a nutrient management plan that addresses all nutrients.
This plan only addresses Nitrogen.
Page 2

WASTE UTILIZATION PLAN
Tahte 2- ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent larakwnew must be attadQ
(Required only if operator does not own adequate land [see
Required Specification 2])
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
See footnote for Table 1.
pe Per Acre* Utilized
..
Totals from above Tables
Acres Lbs. N
Utilized
Table 1 15.96 5,872
Table 2 0.00 -
Total 15.96 5,872
Amount of N Produced 5,630
Surplus or Deficit 242
NOTE The Waste Utilization Plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to prevent over
application of nutrient or other elements.
Page 3

WASTE UTILIZATION PLAN
See attached map showing the fields to be used for the utilization of waste water.
Application of Waste by Irrigation
Field Soil Type Crop Application Application
No. Rate In/Hr Amount In.
1,2,3,E
GoA
Bermuda
0.5
.5-1.0
7
Ln
Bermuda
0.5
.5-1.0
THIS TABLE IS NOT NEEDED IF WASTE IS HOT BEING APPLIED BY IRRIGATION, HOWEVER A SIMILAR TABLE
WILL BE NEEDED FOR DRY LITTER OR SLURRY.
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 MONTHS. In no instance should the volume of
waste being stored in your structure exceed Elevation "see lagoon design.
Call the local Natural Resources Conservation Service (formerly Soil Conservation Service) or Soil
and Water Conservation District office after you receive the waste analysis report for assistance in
determining the amount per acre to apply and the proper application rate prior to applying the
waste.
Narrative of operation: Fields 1,2&6 are based on 400 lbs. Per acre and is the same as the
plan written 2/21/91 and 5/20/96. Field 7 based on current rates. This plan is based on
vetted aeres".
Page 4

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift manmade
cormuyanc.s, diced application, or direct d durkv gmrafiot or lid appk2 iion.
Any discharge of waste which reaches surface water is prohibited.
2 there must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate landon which to property apply the waste. If the producer
does not own adequate land to properly dispose of waste, he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing himlher the
use of the land for waste application. It is the responsibility of the owner of the facility to
secure an update of the Waste Utilization Plan when there is a change in the operation,
increase in the number of animals, method of utilization, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climatic conditions, and level
of management, unless there are regulations that restrict the rate of application for other
nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but less than 10 tons per acre per
year providing grass filter strips are installed where runoff leaves the Field. (See FOTG
Standard 393 - Filter Strip).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6 When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland,
the waste may be broadcast provided the application does not occur during a season
prone to flooding. (See "Weather and Climate. in North Carolina" for guidance.)
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor or flies.
81 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
Page 5

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a
high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste
shall not be applied more than 30 days prior to planting of the crop or forages breaking
dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following_
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and from any perennial stream or river (other than an irrigation ditch or canal. Animal
waste other than swine waste from facilities sited on or after October 1, 1995), shall not be
applied closer than.25 feet to perennial waters. (See Standard 393 - Filter Strips).
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site by a "technical specialist".
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
Page 6

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced as necessary to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied pre -plant with no further applications animal waste
during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste analysis records shall be kept
for five years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for ail other waste shall be maintained for five (5) years.
23
Dead animals will be disposed of in a manner that meets North Carolina regulations.
Page 7

WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm O'red Gurganus Farm
Owner / Manager Agreement
I (we) understand and wig fogmv and implement the specifreabons acid the operation and
rnairderiance procedures estabished m the approved ardmmal chaste utifoahm plan for the
farm named above. I (we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new facilities will require a new
cert;f':cation to be submitted to the Divisican of Environment Management (DEM) before the
new animals are stocked. I (we) also understarW dud dwe must be no dsscharge of
animal waste from this system to surface waters of the state from a storm event less severe
than the 25-year, 24-hour storm. The approved plan will be filed on -site at the farm office
and at the office of the focal Sad and Water Conservation District and will be available for
review by BEM upon request_
Name of Facility Owner: Jody Gurganus
(Please print)
Signature: Date:
Name of Manager (If different from owner):
Name of Technical Specialist: (Please print) Kraig A. Westerbeek
Affiliation: Murphy Family Farms
Address (Agency): P.O. Box 759
Rose Hill, NC 28M
Signature: Date:
Page 8
11 /21 /2001

0
� j
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
February 24, 2004
CERTIFIED MAIL # 7002 1000 0005 2390 0980
RETURN RECEIPT REQUESTED
Mr. Jody Gurganus
Oneal Gurganus Farm
171 Futreal Road
Richlands, NC 28574
Dear Mr. Gurganus:
Alan W. Klimek, P. E. Director
Division of Water Quality
Coleen H. Sullins, Deputy Director
D'nrision of Water Quality
Subject: Notice of Violation and Recommendation for Enforcement
Oneal Gurganus Farm
Facility Number: 67-34
Onslow County
This is to notify you of a violation to Swine Waste General Permit AWG100000.
On January 29, 2004, Mr. Chester Cobb and Mr. John Farrell performed an inspection of your
animal operation and the animal waste management system serving your operation. Upon
review of the irrigation records, the staff noticed that waste had been applied to Field #7 in
excess of the Plant Available Nitrogen (PAN) rate listed in the Certified Animal Waste
Management Plan (CAWMP). The 2003 irrigation records showed that 368.9 lbs PAN / ac had
been applied on Field #7 to Bermuda while a PAN rate of 2001bs 1 ac was listed in the CAWMP
for Bermuda on Field #7. This represents an over application of PAN on Field #7 by 168.9 lbs /
ac. The over application of PAN is a violation of Condition II.4 of the General Permit that
states in part "In no case shall land application rates exceed the Plant Available Nitrogen rate for
the receiving crop or result in runoff during the M given application."
In response to this violation, a Plan of Action must be submitted to this office. This Plan of
Action must include the following:
a. An explanation of the violation.
b. Description of the actions to be taken to prevent the recurrence of the violation
C. A copy of the 2003 irrigation records for Bermuda.
N. C. Division of Water Quality 127 Cardinal Drive Extension [phone] Customer Service
Wilmington Regional Office Wilmington, NC 28405 [phone] Fax [phone] MAW

.4
Mr. Gurganus
Page 2
February 24, 2004
This office must receive the proposed written Plan of Action within fifteen (15) days of yo
receipt of this notice.
You may wish to contact your County Soil & Water Conservation District Office, County
Extension office, a qualified technical specialist, and/or a professional engineer for any
assistance they may be able to provide.
Be advised that this office is considering recommending assessment of civil penalties to the
Director of the Division of Water Quality for the above noted violations. These violations may
result in civil penalties of up to $10,000 per violation in accordance with North Carolina General
Statute 143-215.6A(a)(2). You may also be assessed for reasonable costs of the investigation in
accordance with North Carolina General Statute 143-215.3(a)(9). If you have an explanation for
these violations that you wish to present, please submit your written response along with the Plan
of Action. Your response will be forwarded to the Director along with the enforcement package
for his consideration.
Be advised that the Division of Water Quality may take further action in this matter including
assessment of civil penalties, injunctive relief, and permit revocation.
If you have any questions concerning this matter, please do not hesitate to call Mr. Chester Cobb
at 910-395-3900 ext. 226 or Mr. Steve Lewis at 919-733-5083 ext. 539.
Sincerely,
Rick Shiver
Water Quality Regional Supervisor
Cc: Bill No Onslow County Soil and Water Conservation District
c Fussell, DSWC-WiRO
Kraig Westerbeek, Murphy -Brown, LLC
DWQ Central Files
DWQ Non -Discharge Compliance/Enforcement Unit
Wilmington Files 67-34
54qr -Jac)6s0"' — ��1v� Coe,.
S:1WQS1ANiMALS\ONSLOW12004\67-34 novrfe

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P. E. Director
Division of Water Quality
Coleen H. Sullins, Deputy Director
Division of Water Quality
February 24, 2004
CERTIFIED MAIL # 7002 1000 0005 2390 0980
RETURN RECEIPT REQUESTED
Mr. Jody Gurganus
Oneal Gurganus Farm
171 Futreal Road
Richlands, NC 28574
Subject: Notice of Violation and Recommendation for Enforcement
Oneal Gurganus Farm
Facility Number: 67-34
Onslow County
Dear Mr. Gurganus:
This is to notify you of a violation to Swine Waste General Permit AWG100000.
On January 29, 2004, Mr. Chester Cobb and Mr. John Farnell performed an inspection of your
animal operation and the animal waste management system serving your operation. Upon
review of the irrigation records, the staff noticed that waste had been applied to Field #7 in
excess of the Plant Available Nitrogen (PAN) rate listed in the Certified Animal Waste
Management Plan (CAWMP). The 2003 irrigation records showed that 368.9 lbs PAN / ac had
been applied on Field #7 to Bermuda while a PAN rate of 200 lbs / ac was listed in the CAWMP
for Bermuda on Field #7. This represents an over application of PAN on Field #7 by 168.9 lbs /
ac. The over application of PAN is a violation of Condition H. 4 of the General Permit that
states in part "In no case shall land application rates exceed the Plant Available Nitrogen rate for
the receiving croI2 or result in runoff during the My given aT lication."
In response to this violation, a Plan of Action must be submitted to this office. This Plan of
Action must include the following:
a. An explanation of the violation.
b. Description of the actions to be taken to prevent the recurrence of the violation
C. A copy of the 2003 irrigation records for Bermuda.
N. C. Division of Water Quality 127 Cardinal Drive Extension [phone]
Wilmington Regional Office Wilmington, NC 28405 [phone] Fax
Customer Service
1-877-623-6748
A*A
NCDENR

r
Mr. Gurganus
Page 2
February 24, 2004
This office must receive the proposed written Plan of Action within -fifteen LS) days of your
receipt of this notice.
You may wish to contact your County Soil & Water Conservation District Office, County
Extension office, a qualified technical specialist, and/or a professional engineer for any
assistance they may be able to provide.
Be advised that this office is considering recommending assessment of civil penalties.to the
Director of the Division of Water Quality for the above noted violations. These violations may
result in civil penalties of up to $10,000 per violation in accordance with North Carolina General
Statute 143-215.6A(a)(2). You may also be assessed for reasonable costs of the investigation in
accordance with North Carolina General Statute 143-215.3(a)(9). If you have an explanation for
these violations that you wish to present, please submit your written response along with the Plan
of Action. Your response will be forwarded to the Director along with the enforcement package
for his consideration.
Be advised that the Division of Water Quality may take further action in this matter including
assessment of civil penalties, injunctive relief, and permit revocation.
If you have any questions concerning this matter, please do not hesitate to call Mr. Chester Cobb
at 910-395-3900 ext. 226 or Mr. Steve Lewis at 919-733-5083 ext. 539.
Sincerely,
Rick Shiver
Water Quality Regional Supervisor
Cc: Bill Norris, Onslow County Soil and Water Conservation District
Patrick Fussell, DSWC-WiRO
Kraig Wcsterbeek, Murphy -Brown, LLC
DWQ Central Files
DWQ Non -Discharge Compliance/Enforcement Unit
Wilmington Files 67-34
S:1WQSIANIMALSIONSLOW12004167-34 novrfe

Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per NRCS standards a 100 foot separation shall be maintained between water supply wells and any
lagoon or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Wilmington Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]:---If-you-need. additional -information concerning
this COC or the General Permit, please contact Michelle Barnett at [phone] ext. 544.
Sincerely,
zdel-
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
Wilmington Regional Office, Water Quality Section
Onslow County Health Department
Onslow County Soil and Water Conservation District
Permit File AWS670034
NDPU Files

OF W ArFR Michael F. Easley, Govemor
� Q William G. Rossir., Secretary
1 North Carolina Department of Environment and Natural Resources
co 7
j r Alan W. Klimek, P. E., Director
4 'C
Division of Water Quality
May 1, 2003
Jody Gurganus
Oneal Gurganus Farm
171 FutreaI Road
Richlands NC 28574
Subject: Certificate of Coverage No. AWS670034
Oneal Gurganus Farm
Swine Waste Collection, Treatment,
Storage and Application System
Onslow County
Dear Jody Gurganus:
On April 28, 2003, the North Carolina General Assembly ratified Senate Bill 733 which directs the
---- Division of Water Quality (Division) to extend the expiration date of the Swine Waste -Operation General --
Permit AWGI00000. Therefore, the General Permit has been re -issued by the Division to extend the
expiration date to October 1, 2004. During the period of this extension the Division will be working with
all interested parties on the development of a new version of the Non -Discharge General Permit.
In accordance with your application received on March 11, 2003 and in accordance with the directive of
Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to Jody
Gurganus, authorizing the operation of the subject animal waste collection, treatment, storage and land
application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AWS670034 which expired on April 30, 2003.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Oneal Gurganus Farm, located in Onslow County, with an animal capacity of no
greater than an annual average of 2448 Feeder to Finish swine and the application to land as specified in
the facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or
Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary,
they may be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a
rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until October 1, 2004. Pursuant to this COC' you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
AA
NMM
Non -Discharge Permitting Unit Internet http:/Ai2o.enrstate.ric.us/ndpu
1617 Mail Service Center, Raleigh, NC 27699-1617 Telephone [phone] Fax [phone]
Customer Service Center Telephone [phone]
An Equal Opportunity Action Employer 50% recycledM0% post -consumer paper

Wettable Acres Determination- Certification
Name of Facility: C o ,IG\,,f ^^ Facility NumberAjL- 3q
Owner(s) Name: Phone No: q (D. 324- 3WS
By signing this form, the facility owner and Technical Specialist acknowledge the completion of the
Wettable Acres Determination. All necessary Wettable Acre Determination Field Data Sheets and
calculations were completed to conduct a Wettable Acre Determination. The facility's Waste
Utilization Plan has been amended as necessary to reflect actual wetted acreage. A copy of all
worksheets, calculations, and other Wettable Acres Determination documents, along with the
applicable Waste Utilization Plan and Wettable Acre Determination Certification will be filed with
the local Soil and Water Conservation District. A copy will also be kept on site with the Certified
Animal Waste Management Plan. Any future modifications must be approved by a technical
specialist and filed with the Soil and Water Conservation District pri6r to implementation. If any
modifications to the existing irrigation system or any new irrigation equipment was required to
adequately address the waste management needs of this facility, an Irrigation Specialist or
Professional Engineer has certified the design and installation below.
Owner Name: Q l i
Owner ignature:
Technical`p
S ialist Name: o� E
Technical Specialist Signature:
4e
_a --0- D
If assisted by an Irrigation Specialist or Professional Engineer please read and sign below:
Animal waste application equipment has been designed or modified to apply waste as necessary to
accommodate the waste management plan and according to NRCS Standards. Animal waste
application equipment has been installed according to NRCS Standards and is ready for use.
Irrigation Specialist/PE N
Irrigation Specialist/PE Signature:
Submit this form to:
Attn: Sonya Avant
Non -Discharge Compliance Unit
Division of Water Quality
1617 Mail Service Center
Raleigh, NC 27699-1617
Date:
WADC - 7/99

PRODUCER: O'neil Gurganus
171 Futreal Rd.
LOCATION: Richlands, NC 28574
TELEPHONE: [phone]
TYPE OPERATION: Finishing
NUMBER OF ANIMALS: 2448
(Design Capacity)
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface and/or groundwater. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied. This waste utilization plan uses nitrogen as the limiting nutrient. Waste
should be analyzed before each application cycle. Annual soil tests are strongly encouraged
so that all plant nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and available water holding capacities. Normally waste shall not be applied to land
eroding at greater than 5 tons per acre per year. With special precautions, waste may be
applied to land eroding at up to 10 tons per year. Do not apply waste on saturated soils, when
it is raining, or when the surface is frozen. Either of these conditions may result in runoff to
surface waters which is not allowed under DEM regulations. Wind conditions should also be
considered to avoid drift and downwind odor problems. To maximize the value of nutrients for
crop production and to reduce the potential for pollution, the waste should be applied to a
growing crop or applied to bare ground not more than 30 days prior to planting. Injecting the
waste or disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for analysis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A
NCAC 21-1.0217 adopted by the Environmental Management Commission.
Page 1

MCI'!
_ G M
Amount of Waste Produced Per Year (gallons, fit, tons, etc.)
2,448 animals X 1_9 (tons) wastelanimal/year
Amount of Plant Available Nitrogen (PAN) Produced Per Year
2,448 animals X 22.33 lbs. PANlanimallyear
Guide Std. 633)
4,651 (tons) waste/year.
5,630 lbs. PAN/year. (PAN from N.C.
Tech
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner
The following acreage will be needed for waste application based on the crop to be grown and
surface application:
Table 1: ACRES OWNED BY PRODUCER
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
# No. Type Per Acre Utilized Application
T317
1 &2
GoA
Bermuda(H)
400
12.47
4988
March - Oct
T317
6
GoA
Bermuda(H)
400
0.93
372
March - Oct
T317
7
Ln
Bermuda(H)
200
2.56
512
March - Oct
"* OPTIONAL"
1,2,6,7
Small Grain
50
15.96
798
Sept -April
Total 1 15.961 5,872.00
*This N is from animal waste only. If nutrients from other sources such as commercial fertilizer are
applied, they must be accounted for. N must be based on realistic yield expectation.
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N
requirements. Beginning in 1996 the Coastal Zone Management Act will require farmers in some
eastern counties of North Caroline to have a nutrient management plan that addresses all nutrients.
This plan only addresses Nitrogen.
Page 2

-WASTE.UTF I7`AiT10WPMN
Table 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowner must be attached)
(Required only if operator does not own adequate land [see
Required Specification 2])
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
See footnote for Table 1.
pe Per Acre* Utilized Application_
Totals from above Tables
Acres Lbs. N
Utilized
Table 1 15.96 5,872
Table 2 0.00 -
Total 15.96 5,872
Amount of N Produced 5,630
Surplus or Deficit 242
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to prevent over
application of nutrient or other elements.
Page 3

See attached map showing the fields to be used for the utilization of waste water.
Application of Waste by Irrigation
Field Soil Type Crop
No.
Application Application
Rate (In/Hr) Amount (in.
1,2,3,6
GoA
Bermuda
0.5
.5-1.0
7
Ln
Bermuda
0.5
.5-1.0
THIS TABLE IS NOT NEEDED IF WASTE IS NOT BEING APPLIED BY IRRIGATION, HOWEVER A SIMILAR TABLE WILL
BE NEEDED FOR DRY LITTER OR SLURRY.
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 MONTHS. In no instance should the volume of
waste being stored in your structure exceed Elevation *see lagoon design.
Call the local Natural Resources Conservation Service (formerly Soil Conservation Service) or Soil
and Water Conservation District office after you receive the waste analysis report for assistance in
determining the amount per acre to apply and the proper application rate prior to applying the
waste.
Narrative of operation: Fields 1,2&6 are based on 400 lbs. Per acre and is the same as the
plan written 2/21/91 and 5/20/96. Field 7 based on current rates. This plan is based on
etted acres".
Page 4

REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of waste, he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner of the facility to
secure an update of the Waste Utilization Plan when there is a change in the operation,
increase in the number of animals, method of utilization, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climatic conditions, and level
of management, unless there are regulations that restrict the rate of application for other
nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but less than 10 tons per acre per
year providing grass filter strips are installed where runoff leaves the field. (See FOTG
Standard 393 - Filter Strip).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6 When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland,
the waste may be broadcast provided the application does not occur during a season
prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor or flies.
Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
Page 5

WIS aE UTILIZfATIGU Nl-,
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Waste nutrients shall not be applied in fail or winter for spring planted crops on soils with a
high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste
shall not be applied more than 30 days prior to planting of the crop or forages breaking
dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and from any perennial stream or river (other than an irrigation ditch or canal. Animal
waste other than swine waste from facilities sited on or after October 1, 1995), shall not be
applied closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips).
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner_
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site by a "technical specialist'.
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
Page 6

WASTOWTiLIZ:NT ON PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced as necessary to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied pre -plant with no further applications animal waste
during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste analysis records shall be kept
for five years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
23
Dead animals will be disposed of in a manner that meets North Carolina regulations.
Page 7

WAST UTILIZA-TCON5PMN-.}
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: O'neil Gurganus Farm
Owner / Manager Agreement
I (we) understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. I (we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new facilities will require a new
certification to be submitted to the Division of Environment Management (DEM) before the
new animals are stocked. I (we) also understand that there must be no discharge of
animal waste from this system to surface waters of the state from a storm event less severe
than the 25-year, 24-hour storm. The approved plan will be filed on -site at the farm office
and at the office of the local Soil and Water Conservation District and will be available for
review by DEM upon request.
Name of Facility Owner. Lois M. Gurganus
(Please print)
Signature: Date:
Name of Manager (If different from owner):
Signature:
Date:
Name of Technical Specialist: (Please print) Kraig A. Westerbeek
Affiliation: Murphy Family Farms
Address (Agency):
P.O. Box 759
Rose Hill, NC 28458
Signature: Date:
11 /21 /2001
Page 8

s; Vk
Irrigated Acreage Determination Procedures
for Wastewater Application Equipment
STATIONARY SPRINKLER /GUN SYSTEM
WETTABLE ACRE COMPUTATIONAL WORKSHEET
1. Farm number (identification) Or eA Gw�...�.�.Fieid number (identification) _�Vi eU
2. Irrigation system designation ✓ Existing irrigation system
New/expanded irrigation system
3. Number of stationary sprinklers __ %'a # Interior sprinklers 37 # Exterior sprinklers
4. Wetted diameter —I S ' [feet] from Field Data Worksheet
S. Spacing r) O Sprinkler spacing along lateral [feet]
70 C �O Sprinkler spacing as a percentage of wetted diameter
6. Sprinkler pattern ug Multiple laterals Single lateral
�;
Excessively spaced sprinklers
7. head the irrigated area per sprinkler for the given wetted diameter from the appropriate table and
column based on pattern, spacing, and sprinkler Iocation.
O 'Acres per interior sprinkler from Table S Column 1 )
] Acres per exterior sprinkler from Table S Column C
11 la S 7P
8. Multiply the tabulated irrigated acreage value per sprinkler by the number of sprinklers of each
category in the field. Add all of these. The sum is the total irrigated acreage for the field.
. ►o� (a) Acres per interior sprinkler X _ "7 a # Sprinklers = -7 . 3 `'f Acres
tt r I (b) Acres per exterior sprinkler X 3 # Sprinklers — ``1. 3 a Acres .
1 •'� Total wettable acres for field (Sum: 8a + 8b)
Wettable Acre Computational Worksheet completed by: Date:Qu
Signature of technical specialist

Irrigated Acreage Determination Procedures
for Wastewater Application Equipment
STATIONARY SPRINKLER /GUN SYSTEM
WETTABLE ACRE COMPUTATIONAL WORKSHEET
1. Farm number (identification) Oc e, � G� #ld number (identification)
2. Irrigation system designation ✓ Existing irrigation system
New/expanded irrigation system
3. Number of stationary sprinklers # Interior sprinklers a� # Exterior sprinklers
4. Wetted diameter R 5 [feet] from Field Data Worksheet
S. Spacing n (:�) Sprinkler- spacing along lateral [feet]
tl 690 Sprinkler spacing as a percentage of wetted diameter
6. Sprinkler pattern Multiple laterals Single lateral
Excessively spaced sprinklers
7. Read the irrigated area per sprinkler for the given wetted diameter from the appropriate table and
column based on pattern, spacing, and sprinkler location_
Acres per interior sprinkler from Table Column
Acres per exterior sprinkler from Table Column c-
8. MultipIy the tabulated irrigated acreage value per sprinkler by the number of sprinklers of each
category in the field. Add all of these. The sum is the total irrigated acreage for the field.
(a) Acres per interior sprinkler X # Sprinklers - Acres
1. 1"1 (b) Acres per exterior sprinkler X # Sprinklers - 93 Acres
9 3 Total wettable acres for field (Sum: 8a + 8b)
Wettable Acre Computational Worksheet completed by:
Signature of technical speciatist
Date:
LA
®�
ME
01

Irrigated Acreage Determination Procedures
for Wastewater Application Equipment
STATIONARY SPRINKLER /GUN SYSTEM
WETTABLE ACRE COMPUTATIONAL WORKSHEET
1. Farm number (identification) 0 ne', L " CO64Field number (identification)
2_ Irrigation system designation �� Existing irrigation system
New/expanded irrigation system
3_ Number of stationary sprinklers I6 # Interior sprinklers t 5 # Exterior sprinklers
4. Wetted diameter
q 5 r [feet] from Field Data Worksheet
5. Spacing —7b Sprinklerspacingalong lateral [feet]
-7 C>�20 Sprinkler spacing as a percentage of wetted diameter
6. Sprinkler pattern a3 Multiple laterals Single Iateral
Excessively spaced sprinklers
7. Read the irrigated area per sprinkler for the given wetted diameter from the appropriate table and
column based on pattern, spacing, and sprinkler location_
1 a
Acres per interior sprinkler from
Table S
Column
'J
. 1
Acres per exterior sprinkler from
Table
Column
G
8. Multiply the tabulated irrigated acreage value per sprinkler by the number of sprinklers of each
category in the field. Add all of these. The sum is the total irrigated acreage for the field.
• to (a) Acres per interior sprinkler X �f # Sprinklers = • 'OS 1 Acres
• 11 (b) Acres per exterior sprinkler X 15 # Sprinklers - 1,1 S Acres .
a S Lo Total wettable acres for field (Sum: 8a + 8b)
Wettable Acre Computational Worksheet completed by:
Signature of technical specialist
Date:
\I
0,

CAW14P Wcm bie Arse
Trawling Gun Field Data she 220199
Hard Hose Traveling Gun System
FIELD DATA SHEET *
1. Make and model number S �\S P. mar-"'-(- 1
2. Hose length ��feet ] and hose inside diameter (ID)_inch]
3. Gun make and model number
4. Gun nozzle size b;/�1 [inch ring orifice, taper bore orifice.
5. Gun arc angle [degrees]
6. TraveI lane spacing [feet]. Indicate whether uniform, random.
Number of exterior hydrants . Number of interior hydrants
7. Gun wetted diameter [feet]_ measured, based on gun chart.
S. Gun pressure _ Epsi]. observed at working gauge,
determined from gun charts, calculated (show calculations)
**9. Operating pressure at Hose reel si]. observed at working gauge,
provided by owner.
* * 14. Supply line size [inch] (froth pump to last hydrant).
** 11. Supply line length feet (maximum pumping distance).
* * 12. Supply line type PVC, aluminum.
** 13. Pump make and model number
* * 14. Pump capacity, Igpm].
* * 15. Engine make and model number
or
* * 16. Electric motor horsepower and rpm [hp] � [rpm]
Note: It is strongly recommended that operating pressure at the reel and gun wetted
diameter be field determined. -
* Locate each hydrant on a copy of the map. Indicate the start and stop of the sprinkler cart
for each travel lane and show distance traveled_ Show the location of the supply line.
Irrigated acres will be determined by travel lane
** Optional data, furnish where possible.
*** Information furnished by
and/or
Signature of Owner or Facility Representative Signature of Technical Specialist
Printed Name of Owner or Facility Rrprsentative
Date
Printed name of Technical Specialist
Date
*** Only the person or persons collecting the data should sign the data sheet.

Sheetl
IRRIGATION SYSTEM DESIGN PARAMETERS
Landowner/Operator Name: O'neil Gurganus
Address: 171 Futreal Rd,
Richlands, NC 28574
Telephone: [phone]
Table 1 - Field Specifications
Approximate
Maximum
Useable Size
Field of Field
Number (acres)
Soil Type Slope % Crop(s)
County: Onslow
Date: 11 /21 /2001
Maximum
Maximum
Application
Application
per Irrigation
Rate
Cycle
(In/hr)
(inches) Comments

Sheet7
CALCULATIONS
Sprinkler Specifications
Sprinkler Type: RainBird H30
Nozzle Size:
inches
Sprinkler Pressure:
psi
Flowrate(GPM)-.
gpm
Wetted Diameter.
95 feet
Lane Spacings
Desired Spacing (%):
70 %
Design Spacing(feet):
66.5 "'PVC irrigation pipe normally comes in 20' pieces,
so round to the nearest multiple of 20.
Actual Spacing (feet):
70 feet
Actual Spacing (%):
74 %
Application Rate
Application Rate =(96.3xFlowrate)1(3.1415x(.9xradius)squared)
Design App. Rate =
0.75 in/hr
300 degree arc =
0.90 in/hr
220 degree arc =
123 in/hr
180 degree arc =
1.50 in/hr
Traveller_Speed
Travel speed = 1.605 x Flowrate 1 Desired application amount x Lane Spacing
Desired app. (in.) = inches
300 degree arc = #DIV/O! ft/min
220 degree arc = #DIV/O! ft/min
180 degree arc = #DIV/O! ft/min
Mainline Velocity
Velocity = .408 x Flowrate 1 pipe diameter squared feet/sec.*
*'"For buried pipelines, velocity should be below 5 feet per second
Pipe size: inches
Velocity= #DIV/O! ft/sec.
Page 1

}i ,MapQuest: Driving Directions: North America Page 1 of 2
Fel
A Send IQ r-imler "Ck to utrectlons
Start: Wilmington, NC
Book a Hotel:
US
Save up to 75% an
End: 148 Mack Ln
Orbitz Savers Nationwide!
Richlands, NC
28574-5262 US
Distance: 64.15 miles
Total Estimated Time: i hour, 28 minutes
ie
Driving Directions
......... ......................... ................................................
Distance
..........
❑
................................................... ................................................ ­_.­
1. Start out going South on US-17 BR S/S 3RD ST/US-117 toward DOCK
0.68 Miles
ST.
--...
..........
❑
.....................................................................-......-----..-----......................-----...---..........................................
2. Turn RIGHT onto US-17 BR N/MARKET ST. Continue to follow US-17 BR
1.10 Miles
[]
.......................................................................................................................................................................................
3. US-17 BR N becomes US-74 E/US-17 N/MARKET ST.
3.25 Miles
..........................................
❑
.......... .•....... ............................................................. --..............................................................
4. Merge onto NC-132 N/S COLLEGE RD.
...... I.....
2.30 Miles
..................
❑
.............. ----- .................................................................... .............. ..................................... ............
5. Stay straight to go onto I-40 W.
.............. I ... ..........
34.79 Miles
.............................................................................
❑
................................................................. ...................................
6. Take the NC-41 exit- exit number 385- toward
.... I.- ........
0.30 Miles
...................................................................................
WALLACE/ BEULAVILLE/CHINQUAPIN .
............................................. ..� -.............................................................
❑
7. Turn RIGHT onto NC-41.
10.95 Miles
.............................................
❑
............................................................................................................. .......................
S. Turn SLIGHT RIGHT onto NC-111/NC-1001. Continue to follow NC-111.
--- .....---..-.......
10.24 Miles
.......................................................................................................................................................................................................
❑
.--•--•.................................................................­
9. Turn RIGHT onto BACK SWAMP RD/CYPRESS CREEK RD.
.............----.............................................----.........................................................
0.53 Miles
- oFayett"He J64:1y �p� 41 ` 25 _ � Tre n } *mod ioi
42 tie�,� o.
)� �. 87 ��•o� � ' -� ,. Pallocksville , --
^'oa 8eula�ille '" ., Merrimano ss
Roseboro Md9n011Ao i" `Q`�-c QRiChldnds " a ays !q. e e
lyu,'Y1t1L;ti iI3 -41 ountain 1i81f:IYloDn
n - -�- ROie Nil tp .� Tp i
oAmmon Garland j 3B0 Chid^".�.^= i : ^� Y iNeaDort5,
L=y: 1 • .° y f y t JB�sanvil�e a t "o
;r tTar'Heei= �-* oti cells 'I�fallace ! ( - . ` ?'OtwAV
L �o 390 -- 3 {Piney Greeno . t
�Lurnberten�- Elri 421.0' u_ �--� —
sfo. abetht6wn ; - 7
�a j Fender rr ; Dixon, - —
71ti= Burgdor 4 Sneads Ferry —�
.-Bladenboro 0 0 — -
472 t�kinsom,' �H011Vshelter �� � --
Clarkton� Swamp 4 Holl It�d e T
oProctortille ''a• z t..Kellyr Currie V.. a —r-- - _ ,
C7-7
ouncil' j Leo t surf City —
oEvergreen a - _
� ¢fast Arcadia', ��oHampstead -
s / _ hitevilfe Bottom : , 4 ' : ' E3
fair BluffDelco
-
Brunswick'03
Tabor City ooid Dock 4 �agate�—
Or- o ti i Ms5ont7orvs
-�lst`lµaki
r� 1o�1�i 09soiling Spnag imlces �pcarollna'Beach
oo m i .l a —t's
http://www.mapquest.com/directions/main.adp?do=prt&2n—ONSLOW%2000UNTY& lg... 2/25/2003

MapQuest: Driving Directions: North America
Page 2 of 2
Start:
Wilmington, NC
us
Ica
- 1
,incjtdn t i
ti 42 Mears St 9
�T Iq,AafSTet =
•�ar�el� `� -_- as ` ' x i rN i s
2Qo3bl� uesioom lna o2owaur Ino-,•==-�
End:
148 Mack Ln
Richlands, NC
28574-5262 US
t
Z
102W3 Idla uesf.00m Inc.' 026 ( ;i Inc.
Notes:
............ . . .. ...... .... ...... ...... ... ... . . ... . ............................ ........ ..... .........................
.....•............................. nil in me rc cnr•v ari USE to
i ircrzc�t nn.,rdv l'r
These directions are Informational only. No
representation Is made or warranty g Iven as to their
.................................................................................................................... content, road conditions or route usability or
expeditiousness. User assumes all risk of use.
.......................................................................................................... .. MapQuest and Its suppliers assume no responsibility
for any loss or delay resulting from such use.
... ..... .............................. ..... ... ...................................................
Privacy & I_eaai Naziize3 © 2003 MapQuest.com, Inc. All rights reserved.
http://www. mapquest.com/directions/main.adp?do--prt&2n=ONSLOW%2000UNTY& 1 g... 2/25/2003

V " - .;&pQuest: Maps: print
Page I of I
'7T
A Send To Printer Back to Mao
148 Mack Ln
Richlands NC
28574-5262 US
Notes;
..............
O-RAglrx
Book a Hotel:
Save up to 75% on
Orbitz savers Nationwide!
Booi, Nowl
..ramMee
L
02003 MooQuesimm. Inc.. 02003 GDT. Inc.
All —N,-Its resfary-ed. Use to
A.:
This map Is informational only. No representation Is made or warranty given as to Its content, User assumes all risk of use.
KapQuest and its suppliers assume no responsibillty for any loss or delay resulting from such use
Privagl- P-Ocy & 'Lega; Nat;cez C) 2003 MapQuest.corn, Inc. All rights reserved.
http://www.mapquest.comlmapslprint.adp?mapdata--5SWr5yNjh490lo2bDbIAWtxTXkFOX... 2/25/2003

State of North Carolina
Department of Environrpent_
and Natural Resources 17-C,`� E
FF,'� i d �,IiJ1
Michael F. EasIey, Governo!BY:
William G. Ross Jr., Secretary
Kerr T. Stevens, Director
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Oneal & Lois Gurganus
Oneal Gurganus Farm
171 Futreal Road
Richlands NC 28574
Dear Oneal & Lois Gurganus:
wow
NCDENR
NORTH CAROLINA DEPARTMENT Or
ENVIRONMENT AND NATURAL RESOURCES
February 5, 2001
Subject: Notification for Wettable Acre Determination
Animal Waste Management System
Oneal Gurganus Farm
Facility Number 67-34
Onslow County
A letter dated January 15, 1999 was sent to advise you about concerns associated with Certified Animal
Waste Management Plans and the method by which the irrigated acres within the plans were calculated. Only
the acres that are wetted can be credited in the waste management plan as receiving waste application. Any
acreage within the plan that can not be reached by waste application equipment can not be used as part of your
plan.
. An evaluation by Dean Hunkele on 5M99 was made to review the actual number of acres at your facility
that receive animal waste during land application. The, evaluation of your facility has yielded one of the
following two results as indicated by the box marked with an "X".
Category 1:
❑ The evaluation of your facility could not be completed due to a lack of information. Please
contact your Technical Specialist to assist in providing Dean Hunkele the necessary
information to potentially exempt your facility from undergoing a complete wettable acre
determination. Please submit this information to Dean Hunkele, at 127 Cardinal Drive
Extension, Wilmington, NC 28405-3845, within in 90 days of the receipt of this letter. If you
have any questions please contact Dean Hunkele at [phone]. If within 90 days you
are unable to provide Dean Hunkele with the information you are automatically
required to complete a Wettable Acre Determination as described by Category 2
below, within 180 days of receipt of this letter.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 'Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled110% post -consumer paper

Notification for Wettable Acre Determination
Animal Waste Management System
Page 2
Category 2:
tK Your facility has been identified by the Department of Environment and Natural Resources
as a facility that may have overestimated the number of acres actually receiving animal
waste. Therefore, some or all of your fields may exceeding the allowable loading rates
set in your Certified Animal Waste Management Plan.
In order to resolve this issue, please contact a designated Technical Specialist to have him
or her conduct a Wettable Acre Determination for your facility. The Technical Specialist must
be one that has been approved by the Soil and Water Conservation Commission to conduct
Wettable Acre Determinations. Many Technical Specialist with the N.C. Cooperative Extension
Service, the Soil and Water Conservation Districts, the Natural Resources Conservation
Service, and the Division of Soil and Water Conservation have received this special
designation. You may also contact a private Technical Specialist who has received this
designation, or a Professional Engineer.
All needed modifications to your Animal Waste Management System must be made and
the Wettable Acres Determination Certification must be returned to DWQ within the next
180 days. If the needed modifications are not made and if the form is not returned within the
required time, DWQ will be forced to take appropriate enforcement actions to bring this facility
into compliance. These actions may include civil penalty assessments, permit revocation,
and/or injunctive relief.
Once a Wettable Acre Determination has been completed, a copy of the attached Wettable
Acre Determination Certification must be submitted to the address listed on the form. Please
note that both the owner and the Technical Specialist must sign the certification. A copy of all
the Wettable Acre Determination documentation that applies to your Waste Utilization Plan
must be kept at your facility. DWQ and the Division of Soil & Water Conservation Staff will
review all documentation during their annual visit of your facility. An additional copy must by
kept on file at the local Soil & Water Conservation District Office. Please note that if you install
or modify your irrigation system, a designated Irrigation Specialist or a Professional Engineer
must also sign the Wettable Acre Determination Certification.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Sonya Avant of our
Central Office staff at (9I9) 733-5083 ext. 571.
Sincerely,
Kerr T. Stevens
cc: Wilmington Regional Office
Onslow County Soil and Water Conservation District
Facility File
Murphy Family Farms

RECEIVED
NOV 2 0 2000
BY:
November 15, 2000
Gurganus Farms
171 Futrell Rd. ♦ ♦ Richlands, htC, 28574
Horne Phone [phone] # Email [e-mail] 6
9,3q
Dean Hunkeie
Enviromental Specialist
Wilmington Regional Office - Division of Water Quality
Dear Dean,
This is in response to the Notice of Deficiency you observe on your fly over on September 28, 2000. The hay we had
wind -rowed had been cut and on the ground for approximately two weeks due to the weather and was beginning to
damaged the coastal bermuda beneath it. The hay contractor we contract with ,did not want the hay because it had
begun to rot and he was afraid he might damage his equipment if he tried to bale and remove it. I did not realize the
infractions or implications that could occur from burning the damaged hay on our bermuda fields. I have made
contact with Harry Tyson who is with Soil and Conservation in Onslow County and he has visited our farm and
discussed the ramifications of the situation. I assure you that if our farm needs advice or direction for a resolution in
the future, I will notify Soil and Conservation and you at the Division of Water Quality. There will be no more
burning of wind -rowed hay on our bermuda fields and if we encounter this situation again, we will find a suitable
manner in removing the damaged hay
Sincerely,
Jody G}arganus ;
Y jj`'"
Mack Gurganus;

State of North Carolina
Department of Environment
and Natural Resources
Wilmington Regional OfficeM-4.0;
--ftww t-4
James B. Hunt, Jr., Governor
NCDENR
Bill Holman, Secretary
Ken- T. Stevens, Director
ENVIRONMENT AND NATURAL RESOLRGES
Division of Water Quality
November 8, 2000
CERTIFIED MAI •- �MO-Ob00-0023-4229-84'14 -- -
RETURN RECEIPT REQUESTED
Mr. Oneal Gurganus
Oneal Gurganus Farm
171 Futreal Road
Richlands, NC 28574
Subject: Notice of Deficiency
Oneal Gurganus Farm
Facility Number: 67-34
Onslow County
Dear Mr. Gurganus:
This isto notify Mr. Oneal Gurganus, who holds a non -discharge permit for an animal waste disposal
system pursuant to 15A NCAC 2H .0200 and North Carolina G.5.143.215.1, of a deficiency of Animal Waste
Permit AWS 670034.
On September 28, 2000, 1 conducted an overflight of your animal operation and the animal waste
management system serving this operation. During the overflight, the following observation was made and
is a deficiency of your certified animal waste management plan and General Permit.
Buming of Bermuda Hay Fields
I observed that all the hay fields on your facility and Mack Gurganus'. had been wind -rowed for baling.
However, the rows were being burned on the largest and best quality field in yourwaste utilization plan (see
enclosed photos). This field had been -used as the primary application site this year based on records
observed during your annual inspection on August 29.
Burning hay bales orcut hay is not an acceptable practice for removal of nutrients applied during the growing
season. Burning of fields can be conducted for disease or pest control, -but this should be done after
obtaining written authorization documenting the need from the NC Dept. of Agriculture or NC Cooperative
Extension. I believe that the burning of stubble after hay removal in the fall can be used for field
improvement, but you should check with Extension concerning this and obtain any necessary permits.
127 North Cardinal Dr., Wilmington, North Carolina 28405 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

Mr. Oneal Gurganus
November 8, 2000
Page 2
I know that in the past this farm was grazed to aid in the removal of hay, but no grazing is now being
conducted. It will be up to you to develop a plan for removal and/or use of the hay produced at both
facilities. This can be accomplished through the selling of baled hay, agreement with a hay cutting
contractor, agreement with an area cattle producer, or establishment of a cattle herd of your own at an
appropriate location. The result of Wetted Acres Determinations at both facilities will dictate to what extent,
if any, both farms can be grazed.
To correct or dispute this deficiency, please submit a written response to the Wilmington
Regional Office of the Division of Water Quality that describes the actions to be taken to address this
deficiency of Animal Waste Permit AWS 670034.
The written response must be received by this office within fifteen (15) working days of the
receipt of this -notice. Contact your Service Company, county Soil & Water district office, or county
Extension office for any assistance they may be able to provide.
For future incidents, the Division of Water Quality may issue a Notice of Violation and pursue
additional actions including civil penalties, injunctive relief, or revocation of your Animal Waste Permit
AWS 670034.
If you have any questions concerning this matter please do not hesitate to contact either Mr.
Stonewall Mathis or myself at [phone].
Sincerely,
Dean Hunkele
Environmental Specialist
Enclosures: 1
cc: Bill Norris, Onslow County Soil and Water Conservation
Dianne Roshash, Onslow County Cooperative Extension
Kraig Westerbeek, Murphy Farms
DWQ Non -Discharge Compliance/Enforcement Unit
D`W, _�(3*W�trriii irtrat'Fties- 34
S:IWQSIANIMALSIONSLOW12000167-34 Gurganus NOD.wpd

State of North Carolina
Department of Environment 11kT?WA
and Natural Resources
Division of Water Quality
James B. Hun Jr., JAN Q 3 2000
t, Governo
Bill Holman, Secretary ; BY: -N DENR
Kerr T. Stevens, Director NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
December 30, 1999
Oneal & Lois Gurganus
Oneal Gurganus Farm
171 Futreal Road
Richlands NC 28574
Subject: Fertilizer Application Recordkeeping
Animal Waste Management System
Facility Number 67-34
Onslow County
Dear Oneal &Lois Gurganus:
This letter is being sent to clarify the recordkeeping requirement for Plant Available Nitrogen (PAN)
application on fields that are part of your Certified Animal Waste Management Plan.
In order to show that the agronomic loading rates for the crops being grown are not being exceeded, you
must keep records of all sources of nitrogen that are being added to these sites. This would include nitrogen
from all types of animal waste as well as municipal and industrial sludges/residuals, and commercial fertilizers.
Beginning January 1, 2000, all nitrogen sources applied to land receiving animal waste are required to
be kept on the appropriate recordkeeping forms (i.e. IRR1, IRR2, DRY1, DRY2, DRY3, SLUR1, SLUR2,
SLD1, and SLD2) and maintained in the facility records for review. The Division of Water Quality (DWQ)
compliance inspectors and Division of Soil and Water operation reviewers will review all recordkeeping during
routine inspections. Facilities not documenting all sources of nitrogen application will be subject to an
appropriate enforcement action.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Ms. Sonya Avant of the
DWQ staff at [phone] ext. 571.
Sincerely,
Kerr T. Stevens, Director
Division of Water Quality
cc: Wilmington Regional Office
Onslow County Soil and Water Conservation District
Facility File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Govemor
Wayne McDevitt, Secretary
Kerr T. Stevens, Director
Oneal & Lois Gurganus
Oneal Gurganus Farm
171 Futreal Road
Richlands NC 28574
Dear Oneal & Lois Gurganus:
APR W- 81999
April 19, 1999
AIL"_ I V_T
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RE50URCE5
Subject: Certificate of Coverage No. AWS670034
Oneal Gurganus Farm
Swine Waste Collection, Treatment,
Storage and Application System
Onslow County
In accordance with your application received on December 4, 1998, we are forwarding this Certificate of
Coverage (COC) issued to Oneal & Lois Gurganus, authorizing the operation of the subject animal
waste collection, treatment, storage and land application system in accordance with General Permit
.AWG 100000. This approval shall consist of the operation of this system including, but not limited to,
the management of animal waste from the Oneal Gurganus Farm, located in Onslow County, with an
animal capacity of no greater than 2448 Feeder to Finish and the application to land as specified in the
Certified Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including -civil penalties, criminal penalties, and injunctive relief.
Upon notification by the Division of this COC's expiration, you shall apply for, its renewal. This request
shall be made within 30 days of notification by the Division.
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled(10% post -consumer paper

Certificate of Coverage AWS670034
Oneal Gurganus Farm
Page 2
This COC is not automatically transferable. A ,name/ownership.change application must be submitted to
the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual non -discharge permit by contacting the engineer listed below for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
The subject farm is located in the Wilmington Regional Office. The Regional Office Water Quality Staff
may be reached at [phone]. If you need additional information concerning this COC or the
General Permit, please contact Susan Cauley at [phone] ext. 546.
Sincerely,
4;-K- Kerr T. Stevens
cc: (Certificate of Coverage only for all cc's)
Onslow County Health Department
Wilmington Regional Office, Water Quality Section
Onslow County Soil and Water Conservation District
Permit File
NDPU Files

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
November 6, 1998
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Oncal & Lois Gurganus
Oneal Gurganus Farm
171 Futreal Rd
Richlands NC 28574
Farm Number: 67 - 34
Dear Oneal & Lois Gurganus:
se
. FAME a 8 PST1611 m9
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
You are hereby notified that Oneal Gurganus Farm, in accordance with G.S. 143-215.10C, must
apply for coverage under an Animal Waste Operation General Permit. Upon receipt of this letter, your
farm has sixty (60) days to submit the attached application and all supporting documentation. In
accordance with Chapter 626 of 1995 Session Laws (Regular Session 1996), Section 19(c)(2), any
owner or operator who fails to submit an application by the date specified by the Department
SHALL NOT OPERATE the animal waste system after the specified date. Your application must
be returned within sixty (60) days of receipt of this letter. Failure to submit the application as required
may also subject your facility to a civil penalty and other enforcement actions for each day the facility is
operated following the due date of the application.
The attached application has been partially completed using information listed in your Animal
Waste Management Plan Certification Form. If any of the general or operation information listed is
incorrect please make corrections as noted on the application before returning the application package.
The signed original application, one copy of the signed application, two copies of a general location
map, and two copies of the Certified Animal Waste Management Plan must be returned to complete the
application package_ The completed package should be sent to the following address:
North Carolina Division of Water Quality
Water Quality Section
Non -Discharge Permitting Unit
Post Office Box'29535
Raleigh, NC 27626-0535
If you have any questions concerning this letter, please call J R Joshi at [phone] extension
363 or Dave Holsinger with the Wilmington Regional Office at [phone].
Z
for A. Preston Howard, Jr., P.E.
cc: Permit File (w/o encl.)
Wilmington Regional Office (w/o encl.)
P.b_ Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

State of North Carolina
Department of Environment and Natural Resources wRRECi/
Division of Water Quality �R4�'�rySE VD
Non-Discharge Permit Application Form DEC(THIS FORM MAYBE PHOTOCOPIED FOR USE AS AN ORIGINAL) DE O Q 1998
General Permit - Existing Liquid Animal Waste Gpe, Q,pns
Ischarge The following questions have been completed utilizing information on file with the Di vision ruse
review the information for completeness and make any corrections which are appropriate. If a
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
1. GENERAL INFORMATION:
1.1 Facility Name: Oneal Gurganus Farm
1.2 Print Land Owner's name: Oneal & Lois Gurpanus
1.3 Mailing address: 171 Futreal Rd
City, State: Richlands NC
Telephone Number (include area code): 910-324-3618
1.4 County where facility is located: Onslow
Zip: 28574
1.5 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a.
copy of a county road map with the location of the farm identified): From Chinquapin, take NC 111 S to Fountain, from
Fountain continue on NC 111 S and eo 2.0 miles past Onslow Co. line and turn Rt. onto SR 1209 and co 0.5 miles to farm
entrance on Lt.
1.6 Print Farm Manager's name (if different from Land Owner): Mack Gurganous
1.7 Lessee's / integrator's name (if applicable; please circle which type is listed): Murphy Family Farms
1.8 Date Facility Originally Began Operation: 0 01
1.9 Date(s) of Facility Expansion(s) (if applicable):
2. OPERATION INFORMATION:
2.1 Facility No.: _67 (county number); _34 (facility number).
2.2 Operation Description: Swine operation
Fir to Finish
2448- Certified Design Capacity
Is the above information correct? yes; no. If no, correct below using the design capacity of the facility
The "No. of Animals" should be the maximum number #br which the waste management structures were designed..
Type of Swine No. of Animals Type of Poultry No. of Animals Type of Cattle No. of Animals
Wean to Feeder Layer Dairy
Feeder to Finish Non -Layer Beef
Farrow to Wean (# sow) Turkey
Farrow to Feeder (# sow)
Farrow to Finish (# sow)
Other Type of Livestock on the farm: No. of Animals:
FORM: AWO-G-E 5/28/98 Page I of 4 67 - 34

2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): 16.00 ; Required Acreage (as listed in the AWMP): 16
2.4 Number la o s/ storage ponds (circle which is applicable): ._ L __
2.5 Are subsurface drains present within 100' of any of the application fields? YES or (a (please circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES or (please circle one)
2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, NRCS Standards, etc.) (Swine Only)
YES or NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited? /3 Q
What was the date that this facility's land application areas were sited?
3. REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
Applicants Initials
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations; (1)_e) G
3.2 Two copies of a general Iocation map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit
application for animal waste operations. b
The CAWMP must include the following components:
3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application.
3.3.4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application field.
3.3.8 The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.3.10 A site schematic.
3.3.11 Emergency Action Plan.
3.3.12 Insect Control Checklist with chosen best management practices noted.
3.3.13 Odor Control Checklist with chosen best management practices noted.
3.3.14 Mortality Control Checklist with the selected method noted.
3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility.
3.3.16 Operation and Maintenance Plan.
If your CAWMP includes any components not shown on this list, please include the
additional components with your submittal.
FORM: AWO-G-E 5/28/98 Page 2 of 4 67 - 34

Facility Number: 67 - 34
Facility Name: Oneal Gurganus Farm
RScC-jv5 0 ION
WATCRGMJTY
RUC D 41996
4. A7P�PLICANT' CERTIFICATION: lion -Discharge Permitting
1, l...Y (, 0 G.,C0.(1 ems` .and Owner's name listed in question 1.2), attest that
this application for % t ur NvS 5 (Facility name listed in question 1.1)
has been reviewed by me and is accurate an omplete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned toAne a�'incomplete.
Signature
Date j a_�T��
5. MANAGER'S CERTIFICATION: (complete only if different from the Land Owner)
I, lV 4 e i( _ (Manager's name listed in question 1.6), attest that this
application for (Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned as incomplete.
Signature
Date/A% 3.- 75-7�
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
FORM: AWO-G-E 5/28198 Page 3 of 4 67 - 34

r
,ter
' f
f _ �
Z 'tr

lJ
V LI AT
:x
RECEIVED
WATER QUALITY SECTION
Producer: ' - L ci5 I i. (7r.n_ (,b¢,,t 4.
Location: 171 f_,J 2 r- i V.J
Telephone: '910- 1-7 ! • ��'{
Type Operation:
iZ . cl It AJ 5
Number of Animals: t JI,1 S )im AJ
(Design Capacity)
DEC 0 41998
7 y ; ,�•-• lltan-Discha e p
r9 ermitUng
t
I'lie waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface and/or groundwater. 71ie plant nutrients in the animal waste should
he used to reduce the amount of commercial fertilizer required for the crops in the fields
where the waste is to be applied. 1-his waste utilization plan uses nitrogen',aa thefimiting
nutrient. Waste should be analyzed before each application cycle. Annual soil tests are
strongly encouraged so that all plant nutrients can be balanced for realistic,yields of the
crop to be grown.
Several factors are important in implementing your waste utilization plan in order to
maximize the fertilizer value of the waste and to ensure that it1s; applied -in an
environmentally safe manner. Always apply waste based on the. needs oftile.crop to be,,"I
grown and the nutrient content of the waste. Do not apply more nitrogen than the crop -
can utilize. Soil types are important as they have different infiltration,ratesheaching ,-
potentials, cation exchange capacities, and available water holding capacities.:` -Normally
waste shall not be applied to land eroding at greater than 5 tons per acre -per year. -With" -
special precautions, waste may be applied to land eroding at up to 10 ton"s'per acre per "1
year. Do not apply waste on saturated soils, when it is raining, or when-tliesurface is
fiozen. Either of tlmese conditions may result in runof'fto surface waters which is not
allowed under DEM regulations. Wind conditions should also be considered to avoid drift
and downwind odor problems. '1'o maximize the value of nutrients for crop production,-
and to reduce the potential for pollution, the waste should be applied to. i.growing crop or
applied to bare ground not more than 30 days prior to planting., Injecting the waste or
disking will conserve nutrients and reduce odor problems.
he estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. Acreage requirements should be based on. the waste analysis
report from your waste management facility. Attached you will find infoi6ation on
proper sampling techniques, preparation, and transfer of waste samples to the.lab for
analysis.
f f;',; a #+'. jf F: er4 i
This waste utilization plan, if carried out, meets the requirements for c6trlphance"with.15A
NCAC 21-1.0.217 adopted by the Environmental Management Commission.

T UTT1 P
:... _..; ; w. - x.. 4..
Ainqunt o Waste Produced Per Year allotas N. toirs etc.
Z ra'/R animals X (amt.) waste/animal/year (amt.) waste/year. =
Amount of Plant Available Nitrogen (PAN) Produced Per Year,
animals X-1,3 lbs. PAN/animal/year = rib Ibs. PAN/year. (PAN from N: C. Tech.
Guide Std. 633) Y <t,�;;sg •_`
Applying the above amount of waste is a big job. You should plan time,and have.
appropriate equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on the crop to be grown
and surface application: "' �':'�_._•�.
Table]: ACRES OWNED BY PRODUCER=t-
s '
Tract Field Soil Crop Lbs. N Acres Lbs. N `=r Month of
# No. Tvne Per Ac. * Utilized"" ` Aoolication
Total I% c 1 5590.01
* This N is from animal ivaste on1j,. If nutrients from other sources such as commercial
fertilizer are applied, they must be accountedfor. N must be based on realistic. yield
expectation. 't',-r} `I�• �=�fflYrl � ��r
NOTE. The applicator is cautioned that Pend K nrnl, he over applied while meeting the N
requirements. Beginning in 1996 the. Coastal Zone Management Act will require farmers in
sorne eastern counties of North Carolina to hm-e a nutrient management plan that addresses
all nutrients This plan only addresses Nitrogen.
2

Table 2: ACRES WITH AGREEMENT OR LONG. TERM.LEASEr,.,.
(Agreement with adjacent landowner must be attached)
(Required only if operator does not own
adequate land [see Required Specification 2])
Tract Field Soil Crop Lbs. N Acres Lbs. Nr', Month of .
# No. Tvne Per Ac_ * Utilized Annlication '.
ire
�-
Total
• See foorno[e for 7able L
Totals from above Tables
Acres Lbs. N
Utilized
Table
Table 2
Total
Amount of N
Surplus q Ii
efictt
Ji 8 9a. 0
Produced
.
Z �.6. D ,'F . .
1k=< `1
NOTE: The Waste Utilization Plan must contain provisions forperiodic land
application of sludge at agronomic rates. The sludge will be nutrient richvand will
require precautionary measures to prevent over application of nutrients or other.
elements.
3

i
See attached ntap showing the frelds to be used for the utilization of waste water.
Application of Waste by Irrigation
Field Soil Type Crop Application Application
No. Rate (In/Hr) Amount (in.)
41.
•i-Nt+rah %Et?:f ,,..., ,
TIIIS TABLE IS NOT NEEDED IF WA.SrE IS NOT BEING API'LIF.-D I3Y IRRIGATION. FFOWEVFA A SM49ARTABI.E WILL
IM Nr:13UF D FOR DRY LnTER OR SIX" Y.
Your facility is designed for IPV days of temporary storage and the temporary' storage
must be removed on the average of once every(p MONTHS. In no in should
the volume of waste being stored in your structure exceed Elevation
Call the local Natural Resources Conservation Service (formerly Soil Conservatiolr
Serikej or Soil and Water Conservation District office after you receive the waste'
analysis report for assistance in determining the amount per acre to apply and the proper
application rate prior to applying the waste.
Narrative of operation: NIA.� 6 Az f of A ` fi a I Ls
A%(trt �{'le" E ftf.1g1 Z.' I-1` li 0.
I)f .r el r►j R.R�1 r3 n � t c r:: 7.G -'�. AI-," ?4 jhLi.'- hm,(i i4 �•
YIArt: �.(nCL /l^.y ACr.a.; f�� �1r,�a;r �*►� Da4t�
4

MIZATI
WASTE UTILIZATION PLAN AGREEMENT J-,,,
4 Name of Fat -in:
Owner/Manager Agreentent
I (we) understand and will follow and implement the specification and the""61
maintenance procedures established in the approved animal wake utilizatio�'M
7. 'VO
rann named above. I (we) know that any expansion to th6-existing 6gn si"' �O
—
waste treatment and storage system or construction of new facilities wills
certification to be submitted to the Division of Environment ManagenientAL
the new animals are stocked. I (we) also understand that there -must be-'rio-N
animal waste from this system to surface wasters of the state from a.storm
,
severe than the 25-year, 24-hour storm. The approved plan wfllbefiIdd*'6nI
farm office and at the office of the local Soil'and Water Conservation DistHi
available for review by DEM upon request.
A
Name of Facility Owner: L a ckz s &tTL!aAW4-S
(Please P-int)
Signature �Q, Date:
Name of Manager(If different from owner):
Signature:
Date:
Name of Technical Specialist: (Please
jw
print)__ d4�.l
Affiliation:
rVNj,
T%\ S
Address (Agency): 111k,7 V�,
rrw�. I!, rip O"s
-7
J,
A, "D RI
L
Signature:
Date:
W
8

-ji-
14 —A
Ob* ..'r
14C Jm
c TA
e e
46
J6
ALE
�tk
d1b
tit_
'law t
A�k
7,
w�t
ww

F 02 �_c
.t
,'cis..,
y,p �'
� /yr�(�,.].�3�� �; •w
- i«!
'•Rd"Wo
�
•Y7 -
�) per...•!, � �1 •�-J .ty, ���

]a
0 R
41
0
S!it
RW~ QWM
�q r ll" ''•., 'r �, i.r M.If Mea,�. pbsr — - Lars .1�f rw5t
W `r
40p1 w�
a'. My +� • '
3 v �F
o W rr /
nre wl =d CK50N"
,a
> ra
jl 1„1129.' `- T r r LIMP
dffiA
0
.i
` ra
,a Ake., .�./- ^rw • 'i�x o(,ir
+\ ,rrr, - J! • llp � lit Vra -
1„i
- r
\\ rru rfof 1.7 17 UR 1
S ,� r4ti
, w �
1+ t G F F A T c A N
1A U N
�,
ra
•� � •.qof. r yr
p ground. In bad weather \ > f
leaf litter and along the \
probe the soil for worms
\ ,M
eir strong, sensitive bill. `�S � j ' • �-�" : fi) ,�
ock takes no part in the in- p \A-6

- -. ,. ',_ . .,
TELEPHONE NUMBERS
DWQ 910 395-3900
EMERGENCY MANAGEMENT SYSTEM 910- 3474270
SWCD 910- 455-4472
NRCS 910- 455-4472 -
This plan will be implemented in the event wastes from your operation are leaking,
overflowing, or running off site. You should not wait until wastes reach surface waters or
leave your property to consider that you have a problem. You should make every effort to
ensure this does not happen. This plan should be posted In an accessible location for
all employees at the facility.. The following are some action Items you should take.
I. Stop the release of wastes. Depending on the situation, this may or may not be
possible. Suggested responses to some possible situations are listed below.
A. Lagoon overflow - actions Include:
1. Add soil to berm the increase elevation of dam.
2. Pump waste to fields at an acceptable rate.
3. Stop all flows to the lagoon immediately.
4. . Call a pumping contractor.
5. Make sure no surface water is entering lagoon.
B. Runoff from waste application field - actions Include:
1. Immediately stop waste application.
2. Create a temporary diversion to contain waste
3. Incorporate waste to reduce runoff.
4. Evaluate and eliminate the reason(s) that caused the runoff.
5. Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinklers - actions Include:
1. Stop recycle pump.
2. Stop irrigation pump.
3. Close valves to eliminate further discharge.
4. Repair all leaks prior to restarting pumps.
D. Leakage from flush systems, houses, solid separators - actions Include:
1. Stop recycle pump.
2. Stop irrigation plump.
3. Make sure no siphon occurs.
4. Stop all flows in the house, flush systems, or solid separators.
5. Repair all leaks prior to restarting pumps.
Page 1 of 3

E. Leakage from base or sidewall of lagoon. Often this Is seepage as opposed
to flowing leaks - actions Include:
1. Dig a small well or ditch to catch all seepage, put in a submersible pump, and
pump back Into lagoon.
2. If holes are caused by burrowing animals, trap or remove animals, fill holes and
compact with a clay type soil.
3. Have a professional evaluate the condition of the side walls and lagoon bottom
as soon as possible.
Il. Assess the extent of the spill and note any obvious damages.
A. Did waste reach any surface waters?
B. Approximately, how much was released and for what duration?
C. Note any damage, such as employee injury, fish kills, or property damage?
D. Did the spill leave the property?
E. Does the spill have the potential to reach surface waters?
F. Could a future rain event cause the spill to reach surface waters?
G. Are potable water wells in danger, (either on or off the property)?
H. How much reached surface waters?
111. Contact appropriate agencies.
A. During normal business hours, call your DWQ (Division of Water Quality) regional
office; phone [phone]. After hours, emergency number: 919-733-3942. Your
phone call should include: your name, facility, telephone number, the details of the
incident from item 11 above, the exact location of the facility, the location or direction
of movement of the spill, weather and wind conditions. The corrective measures
that have been undertaken, and the seriousness of the situation.
B. If the spill leaves the property or enters surface waters, call local EMS Phone
number 910- 347-4270
C. Instruct EMS to contact local Health Department.
D. Contact CES, Phone number 910455-5873, local SWCD Office phone number 910
455-4472, and local NRCS office for advice/technical assistance phone number
910- 455-4472 -
IV. If none of the above works call 911 or the Sheriffs Department and explain your
problem to them and ask that person to contact the proper agencies for you.
V. Contact the contractor of your choice to begin repair of the problem to minimize
off -site damage.
A. Contractor's Name:
Page 2of3

B. Contractor's Address:
C. Contractor's Telephone:
VI. Contact the Technical Specialist who certified the lagoon (NRCS, Consulting
Engineer, etc.)
A_ Name: PIN
B. Telephone: Lf .-S`' a .Z
VII. Implement procedures as advised by DWQ and technical assistance agencies to
rectify the damage, repair the system, and reassess the waste management plan
to keep problems with release of wastes from happening again.
Page 3 of 3

Additional Information: Available from:
Swine Manure Management; 0200 RuWBMP Packet NCSU, County Extension Center
Swine Production Farm Potential Odor Sources and Remedies; EBAE Fact Sheet
NCSU - BAE
Swine Production Facility Manure Management: Pit Recharge - Lagoon Treatment; EBAE 128-M
NCSU - BAE
Swine Production Facility Manure Management: Underfloor flush - Lagoon Treatment; EBAE 129-89
NCSU - BAE
Lagoon Design and Management for Livestock Manure Treatment and Storage; EBAE 103-83
NCSU - BAE
Calibration of Manure and Wastewater Application Equipment; EBAE Fact Sheet
NCSU - BAE
Controlling Odors from Swine Buildings; PIH-33
NCSU - Swine Extension
Environmental Assurance Program; NPPC Manual
NC Pork Producers Assoc.
Options for Managing Odor; a report from the Swine Odor Task Force NCSU Agri Communications
Nuisance Concerns in Animal Manure Management: Odors and Flies; PRO107, 1995 Conference Proceedings Florida Cooperative Extension
file: C:IVlrndows\Persona1102001Odor Control Chlcdst.doc
4 December, 1997
Page 4 of 4

Source Cause BMP's to Minimize Odor Site Specific Practices
Manure, slurry or sludge • Agitation when spreading; ❑ Soil injection of slurry/sludge's;
spreader outlets . Volatile gas emissions ❑ Wash n3sidual manure from spreader after usage;
❑ Proven biological additives or o)adants
Uncovered manure, .
Volatile gas emissions while
❑ Soil injection of slurry/sludge's;
slurry or sludge on field
drying
❑ Soil incorporation within 48 hrs.;
surfaces
❑ Spread in thin uniform layers for rapid drying;
❑ Proven biological additives or oxidants
Dead animals .
Carcass decomposition
91<mper disposition of carcasses
Dead animal disposal .
Carcass decomposition
❑ Complete covering of carcasses in burial pits;
pits
❑ Proper location/construction of disposal pits
Incinerators .
Incomplete combustion
❑ Secondary stack burners
Standing water around .
Improper drainage;
Grade and landscape such that water drains
facilities • Microbial decomposition of away from facilities
organic matter
Manure tracked onto . Poorly maintained access roads 2tarm access road maintenance
public roads from farm
access,
Page 3 of 4

Source
Cause
BMP's to Minimize Odor Site Specific Practices
Pit recharge pants •
Agitation of recycled lagoon
❑ Extend recharge lines to near bottom of pits
with ardi-siphon vents
Lift stations •
Agitation during sump tank
❑ Sump tank covers
filling and drawdown
Outside drain collection .
Agitation during wastewater
❑ Box covers
or junction boxes
conveyance
End of drainpipes at •
Agitation during wastewater
Falgend discharge point of pipes underneath
lagoon
conveyance
lagoon liquid level
Lagoon surfaces .
' Volatile gas emissions;
Proper lagoon liquid capacity;
Biological mixing;
❑ Correct lagoon startup procedures;
•
Agitation
nimum surface area -to -volume ration;
gMinimum
agitation when pumping;
❑ Mechanical aeration;
biological additives
Irrigation sprinkler • High pressure agitation; Mff e on dry days with little or no wind;
nozzles . Wind drift Fgatimum recommended operating pressure;
L—KPump intake near lagoon liquid surface;
❑ Pump from second -stage lagoon
Storage tank or basin • Partial microbial decomposition; ❑ Bottom or midlevel loading;
surface • Mixing while filling; ❑ Tank covers;
• Agitation when emptying ❑ Basin surface mats of solids;
❑ Proven biological additives or oxidants
Settling basin surface • Partial microbial decomposition; ❑ Extend drainpipe outlets underneath liquid
• Mixing while filling; level;
• Agitation when emptying ❑ Remove settled solids regularly
Page 2 of 4

Source Cause Ie- BMP's to Minimize Odor Site Specific Practices
Farmstead • Swine Production ZVegeMve or wooded buffers;
best management practices;
judgment and common sense.
Animal body surfaces • Dirty manure -covered animals Q'Dry Floors
•
p'Waterers located over slotted floors;
9fj ers at high end of solid floors;
Scrape manure buildup from floors;
❑ Underfloor ventilation for drying
Manure collection pits • Urine; requent manure removal by flush, pit
• Partial microbial decomposition recharge, or scrape
❑ Underfloor ventilation
Ventilation exhaust fans • Volatile gases;
maintenance
[efficient air movement
Indoor surfaces • Dust aj Washdown between groups of animals;
❑ Feed additives;
❑ Feeder covers;
❑ Feed delivery downspout extenders to
feeder covers
Flush tanks • Agitation of recycled lagoon ❑ Flush tank covers;
liquid while tanks are filling ❑ Extend fill lines to near bottom of tanks with
anti -siphon vents
Flush alleys • Agitation during wastewater ❑Underfloor flush with underfloor ventilation
conveyance
Page 1 of 4

Source Cause BMP's to Control insects Site Specific Practices
Inspect for and remove or break up accumulated
wastes in filter ships around stockpiles and
manure handling areas as needed.
For more information contact the Cooperative Extension Service, Department of Entomology, Box 7613, North Carolina State University,
Raleigh, NC 27695- 7613
Page 3 of 3

Source Cause BMP's to Control Insects Site Specific Practices
Feed Storage + Accumulation of feed residues Reduoe moisture accumulation within and
around immediate perimeter of feed storage
areas by insuring drainage away from site
andlor providing adequate containment (e.g.,
covered bin for brewer's grain and similar high
sture grain products).
Inspect for and remove or breakup
accumulated solids in filter strips around feed
storage as needed.
Animal Holding Areas + Accumulations of animal vmstes ❑ Eliminate low areas that trap moisture along
and feed wastage fences and other locations where waste
accumulates and disturbance by animals is
minimal.
❑ Maintain fence rows and filter strips around
animal holding areas to minimize accumulations
of wastes (i.e., inspect for and remove or break
up accumulated solids as needed).
Dry Manure Handling + Accumulations of animal wastes ❑ Remove spillage on a routine basis (e.g., 7 - 10
Systems
day interval during summer, 15 - 30 day interval
during winter) where manure is loaded for land
application or disposal.
❑ Provide for adequate drainage around manure
stockpiles.
Page 2 of 3

Source cause BMP s. to Control Insects Site Specific Practices
Liquid Systems
Flush Gutters . Accumulation of Solids ❑ Flush system is designed and operated
sufficiently to remove accumulated solids
from gutters as designed.
@`Remove bridging of accumulated solids at
Lagoons and Pits . Crusted Solids [ Maintain lagoons, settling basins and pits
Mere pest breeding is apparent to minimize
the ousting solids to a depth of no more
than 6 - 8 inches over more than 30% of
Excessive Vegetative • Decaying Vegetation Ef Maintain vegetative control along banks of
Growth lagoons and other impoundment's to prevent
accumulation of decaying vegetative matter
along water's edge on impoundment's perimeter.
Dry Systems
Feeders . Feed Spillage Design, operate and maintain feed systems
(e.g., bunkers and troughs) to minimize the
amimulation of decaying waste.
Clean up spillage on a routine basis (e.g. 7 - 10
day interval during summer, 15 - 30 day interval
during winter).
Page 1 of 3

(check which methods are being/to be implemented)
o Burial three feet beneath the surface of the ground within 24 hours after knowledge of
the death. The burial must be at least 300 feet from any flowing stream or public body
of water.
Rendering at a rendering plant licensed under G. S. 106-168.7.
o Complete incineration.
o In the case of dead poultry only, placing in a disposal pit of a size and design
approved by the North Carolina Department of Agriculture.
o Any method which in the professional opinion of the State Veterinarian would make
possible the salvage of part of a dead animal's value without endangering human or
animal health. (Written approval of the State Veterinarian must be attached).
Re: lWhoft.clac
4 December, IOU
Page 1 of 1

U. S. Department of Agricul cure Vedp"i
Soil Conservation Service 7Ip
Filb&de: 210 N
S 7 Zr 9, aa,v d Q 199b
HAZARD CLASSIFICATION DATA SHEET FOR , E �Non _
Landowner ei L Y Count '`' ` Dr cha a FsrMiM.
Community or Group No. Conservation'Plan'No1
Estimated Depth of Water to Top of Dam C - S Ft. Length of Flood 'Pool"" 310 'Ft.
Date of Field Hazard Investigation 9/ 9
Evaluation by reach of flood plain downstre,#m to the point of estimated minor effect
from sudden dam failure.
s ev:1'-. s Elevation
Kind of :Improvemen si�" of'Breach
Reach: Length: Width: Slope:.' Land -Use Improvements 'Above"W- Floodwater Above
Flood.,Plain:: Flood Plain
Ft. Ft. t:
2
Ir M.
Describe potential for loss of life and damage to existing r xPobable fu ure downstream
improvements from a sudden breach a
i1:0'
Classification of a b, c) (see HEM -Part 520.21)
�4ftm Classification (I, II, III, 6, V)
By
Concurred By
name title
NOTE: 1. Instructions on reverse side.
2., Attach additional sheets as needed.
Date
Date

INSTRUCTIONS
:r
All dams built with technical assistance from the Soil Conservation Service
must have a hazard classification assigned by the person'responsible for -,--
approving the design. Most farm ponds, -,except in border)ine'cases, can
be classified after a complete field investigation without assuming failure ,.
and making breach studies. This data sheet is to be used -for recording
the information obtained through field studies and for -documenting -the k •,
hazard classification. Where there is a possibility for loss of life or s
major property damage from a dam failure, an approved breach,"routing :.t
procedure is to be used. (Consult with the area engineer.)+
Hazard classifications of cams are -made by evaluating the_'poss;i;bility ;:.,s.i;�l:. For
for loss of life and the extent of damage that would result -if the dam
should suddenly breach --that is --a section of the dam be -suddenly, -and
completely washed out.. It is to be assumed that a wail of -water will be
released equal to the height of .the dam. This flood waver'wil#bedreduced, ,i r_ r
in height as it moves down the flood plain. The wave height: depth,of
flooding) should be evaluated for a sufficient distance downstream'until7"
the estimated flood level will not cause'significant damage`to�`improvements,
such as homes, buildings, roads; utilities, reservoirs, etc:r The breach ,
flood level will be reduced depending on the valley storage;;slope,'and
openess of the flood plain; however, in a narrow steep'valley'•slopes---
steeper than 10% should be given special consideration. One'method.of
evaluation is to compare available valley storage (under flood conditions)
to impoundment storage (figured to the top of the dam) for each reach
evaluated with a judgment estimate made of the flood wave height-at:all
critical points downstream.
Should there be any questions about the hazard classification for a'dam,
the area engineer should be consulted before making design`•coimmitmentsi"
1
4

A.
r SCS-ENG-538 i � -'�'.�, S.:pEPARIMENT Of AGRICULTURE
Rev. 5-70 90IL Ok5ERVATION SERVi
SOIL INVESTIGATION TO DETERMINE.SUITABILITY _,'OF .W P �41010 SITE
FARMER'S NAME DISTRICT` —
DATE COUNW
PHOTO • _
r�
CROPtAND—ACRFS PASTURE —ACRES
i
WOODLAND —ACRES TOTAL ACRES
SKETCH OF • i eft SHOWING WHERE BORIWG7S WERE A0jDE-(AvPh*:'/
L-48�Mate reference point in center line of dam and Idenft on skitc&
ONE
■ill
!MI■
■
■
®■1®f���■■I�l®®®
in
1111■■■
_
�
■■■■
��ie
�®®�
�-gloom.
■■I1�■■
■■■■■■■■t■Is■i®®11®■1■■■'
III■■■■
■�■■■/%■�■®1®11®II■■■
■■■i■■■i■■■e■■e■■.�■®■■®■■■
BORING NUMBER ANDMake
and I;sl dam -site and spillway borings first- then ponded area and borrow pit borhwiiiisi6rdfe with vd, Indima.
cd on back where necessary) Show water table elevations on darn -sift borfnp..
mo�o!o��
M
'MINIM
®E�
�ItI�®'4®®I®■�■!■I®44�i®i44�1
��i�
I}}�'�!44����!
®MOO
I�■!®;4®I�■!■■i�JFlF�i®1�4���i®®I
JJli!�IliIETE.
®m
r.z.I��I�II■I■i�■I■
■i■�®II®I!4I®��!
!
!
®IiI�I®OEM
®�ml■I®t��
■I■I■I®III'®!�
�1�',®���®I
`■I®
I�®!�
L.;3d�
13ORINGS MADE; BY,#--rnW— SIGNATURE & TM9'-
, ...+. }—._..q.r..—.��. :. //"'!.7'.°"'••"w ems•... ��

j
TYPES OF MATERIAL ENCOUNTEREDIN,1309INGS,
(Use. one of systems below)
UNIFIED CLASSIFICATION
USDA CLASSIFICATIOW-L41a.'.
GW-Well graded grovels; gravel, sand mix.
g-gravel
GP -Poorly graded gravels f
s - sand
GM -Silty grovels; gravel -sand -silt mix
vfs - very fine sand
gzm.
GC -Clayey gravels; gravel -sand -clay mix
st- sandy loam
SW - Well graded sands; sand-grAvel mix
fsl-fine sand loam
SP - Poorly graded sands
1-loam
q0 ;ovl.7�
SM- Silty sand
gl -gravelly loam
SC -Clayey sands; sand -clay mixtures
Si -silt
ML L Silts; Silty, v. fine sands; sandy or clayey silt'
sil-silt loam
A—
CLi.-Clays of low to medium plasticity
cl - clay loam
CH -Inorganic clays of high plasticity r
sicl - Silty clay loam
MH� Elastic silts
OL-Organic silts and Silty clays, low plasticity
scl-sandy clay loam
sic -silty CL8y
4
OH -Organic clays, medium to high plasticity
c- clay
1. Suitable material for embankment is available Oyea 0 No Ondicalk where fowtm4
th*-6*eki
on.
1"P*4 SM40
=
REMARKS:
. .
. . . . . .
_Q4
I Explain hazards requiring special attention in design
(Srawpe, sVrtnV_rMk-ejr_)
V
GENERAL REMARKS.
_7
Ir.1 rR,
rF�
A
4
24
125 JIM
1 27
28129130
H 31
32
1 W JIM
136
36
37
M
39
40
41
42
43
44
fo
4-1
1-.48i
49
IM
51
r46Stt
RI
3,
IL,
VV
V
V.
I
k
iL!�
1 -4
7T
1
11 1
11
1 11__
I
I 1L
11
±1

OPERATION AND MAINTENANCE PLAN ... ;:�� n--
_ Onei 1 B. Gurganus
This lagoon Is designed for waste treatment with minimlmum;adc-'rcvntrol.
The time required for the planned fluid level to be reached";mayf'wary'rdue to
soil conditions, flushing operations, and with no fresh wate0,4'6dded to;,.the
system. Plans are to recycle waste water In the flushing vpOtativn.'.�.,.-,,,,
Land application of waste water is recognized as an acceptable:method-of"
disposal. Methods of application Include honey wagons.(5pre,yer.'or�.in ection)
for small operations and Irrigation (center pivot, Care.
needs to'be taken when applying waste to prevent damage.!to.&0o _de runoff
from the field.
The following items are to be carried out:
1. Bcgin pump -out of the lagoon when fluid level reaches'_invert'aV outlet
i es.
P P LEI/ S S. S
2. Stop pump -out before fluid depth is less than 5 feeVd6ep,;;(thlsAprevents
the loss of favorable bf.cteria): FLE-V. S3. Z
3. The recommended maximum amount to apply er.irri ation=is�:one .inch, and
PP Y p 9 ,.,.
maximum recommended application rate is 0.4 inch per
4. it is strongly recomnierded that the treatment lagoon:beSkecharged tv,=
1/2'its capacity to prevent excessive odors during startup:�:iPrechargfng
reduces the concentration of the initial waste enter ingAthe"IagooWtherety,,' .
reducing odors. Solids should be covered with effluent at*�all-..times:
5. Keep vegetation on the embankment and areas adjacent':tothe"lagvor,mc►wed-
b. Repair any eroded areas and establish in vegetation.�.rt
7. The Clean Water Act of 1977 prohibits the discharge.of pollutan.ts..Into
waters of the United States. The Department of Natural-Resour.ces'and`Community
Development (DNRCE,), Wastewater Management Section, has-thd"`';e' nsibillty' .
for enforcing this law.
8. All surface runoff is to be diverted from the lagoon..zto"ddequate outlets.
NOTE: An analysis of the waste water cGn be obtained atcomroFrcial~-
laboratories or at a fee of $1.00 per sample at: F'' .•
N.C. Department of Agriculture Plant Analysis Lab
Agronomic Division
Blue Ridge Rcad Center
Raleigh, N.C. 27611
Phone: [phone]

r= -•.' 1
�]
United statai
Department of CoMservatian
Agriculture Service
OPERATOR: Onei 1 B. Gurganus
Please review the attached plan and specifications
carefully:'*Retain-.fix?(
this plan for your use and records. It Is strongly recommehjed tha-jlt 'you;=:
your contractor, and Soil Conservation Service
personnW,.a�� 91, agr rrierit, "
as to how the waste lagoon is to be constructed.'-
The -Sol ICansefv'aton';.
Service personnel wlII meet with al I concerned
parties ­and�kaTik,_dveF� the ;
site to explain all flags and markings. It Is
important`vtht..everyone.
understand what is expected so thfat final cons tructIon.tneets
plans and
specification and the Job can be certified for
payment :(IF.�dos,t;=shar,Ing
is Involved).
-�sl
The pad 'dimensions and grades are the best estimate:.
The 8UILDER.or
CONTRACTOR is RESPONSIBLE for final layout and
design of 17the'{pads:-'�-`7The
Soil Conservation Service personnel will assist
in a-ltr0led capacity,
as its major concern is the proper design and construc
waste -
treatment lagoo
The actual amount of material required For pads
and' dam may'•'veCy: from'.the " -
estimates. The design will attempt to balance
cuts and'f,11:1§fi-- lose 1isf
possible. If additional material Is required after
cons ti'ucti;iori'�is :c6mplete
on the lagoon, the contractor and owner wi l l negotiate
on,.tlie;'priCe `and;`-- (-
location of borrow area.
��;4 " 's'"•
�-
NOTE: Design Requirement.
- /8G6I cu;'yds
��02,237cu.ft.
Estimate Excavation:
'° "''' �•' Yds.
of cu.ft.
Estimate of Pad b Dike: �_cu.€t.
a U. yds .'''`
/ 7'
Rations:
Job Class
Date
Designed By
3�
Name
Design Approval
s_ _ --
Name,.
Date:'y
s
,'` ,
SOa Conlllrvalion 91rvIC6
OThy
to Sgoney of the
aafritrlmanl 61 /grlcullur•

.L'II-�S.1L W;LSTE K;JIACc=LT'_rT Pi.A!I Poyk E:tIS'?:7G FEEDLOTS
?leans retuzz-o the completed fcrm to the Divinion of En%ii onmdn_al ?iaYascLMpvt at
tin add ese on the reverse side. of thin
i a�,e a_ :era (Please in,51C�e,�ti9A14LL
Ma : l i nc :cores s : L L E —; ai ijC--Z_
Phone- No. : dD—
Count•. (o; (`arm) S s
=at-- location: Latitude and Longitude 3� � SD /V :� 1(reguiied)•. Aiso.
please attach a copy of a county road map with location ide'n ie�-
!'fpe of operation (swine, layer, dair-v, etc.) : ZYSf$.-~. .OJ1' 3oj!%
Desicr. caaacity (number of animals) : _ 244-M& 41 $ _
Average -size of operation (12 month population avg.) -._:
Average acreace needed for land application of waste (acres)-:_
`
Tachnical Specialist Certification 1
As a technicaj specialist designated by 'the North Caro?inz Soil and Water
Conservation Commission pursuant to 1SA NCAC 6r .0005:'r';I certify that the
existing animal waste management system for the farm named*'above;.has an animal
_;6_;ZC Plan t at. —naetn the
speci`ications of the Division of F. viror,mental Nanagesment a.:d}.the USDA-Soi_
Conservation Service and/or the North Carolina Soil'ane Eater Conservation.
Corr^lission pursuant to 1SA NCAC 2}(.0217 and 15A 14CAC".,4F'>>0001--.0005. The
fol?owir:g, elements and their corresponding minimum crit_eria-have been veri_`iec
DV me or other designated technical specialists and are included ir. the plan as
applicable: minimum separations (buffers), adequate quantity'znd amount of lane
for waste utilization (or use of third party); access-• oi:,ownership•af'•,prope_
-caste application equipment; schedule for timing of applications: appl+cation
rates; loading rates; and the control of the discharge -No: pollutantsfrom
stoirnwate= runoff events less severe than the 25-ye r, -24-hour,st6rm•:, ,fir'; `
• .gyp• +� ;=�',• .
11=a of Technical Speci�j��iet (Please Print) s
-fi? iation (:agency) �"l
A
Acc- e s s Phone N6.=-=�/0
Signature: 66SDate 5'2.a
-
0---ner /!tanager A6 ree.m
(we) understand the operation and maintenance r is
procedures established the
approved anima; waste manaee-mer:: plan for t:Ze farm named zibove and. wi ll irple-mer:_
_ -ese procecures. 1 (we) )crow that anv e�cpznsion to the ezis41,:e. design caGac t
Of :rle waste t=eat„'stent-<3nd s: orage system cr construc::ioh. of ne- idcil'ities
e uire a new certificaLio: to be suiomitt-cc3 to the•fai%%;sion of,,.Er:rirotmer.ta,
;_
'..anaaemer` be -ore the new animals are stocked. I (we) also"unde:stand tha_ ^ere
x-
.> st be no discharge of a.Iti:na3 waste From this systerrito`su.-faca %,;aters c- t`-e
state eiLler d_rectiy. Ehr'o�_,gh a man-made coyivevance_ori',jcnr0L;gn Lit;1J1ti __U!n
storm event less severe than. the 25-yea:., 24--h6ur storm.".The approved plan will'
he filed at the far-m and at the off ice of the local ;Soil `and Water Cor.serva�io,-
D, strict . .rfl`
;nee of Laad owner (n_e,- a* i::t)
o%-ne: 1: :case print) _s-------------
.:�5^ c:..-..;err.- -.. _..,'•ei ,:-...--.... ,_, ,r- _.r• .. •. `.•..� ,. ��rv--.^- --- :-. :
. ...-r.�-C•�n:. �f._.. 1.. .ill ir.�(` ) 1.=- 1'. C.•, •i i '
• }g
,
. 1 :
A � �
t f

V4. t_�u
State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E.,
Oneal & Lois Gurganus
Oneal Gurganus Farm
171 Futreal Rd
Richlands NC 28574
Dear Oneal Gurganus:
RECEIVED
JAN 0 4 1998
BY: NCDENR
Director NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
December 30, 1998
Subject: Application No. AWS670034
Additional Information Request
Oneal Gurganus Farm
Animal Waste Operation
Onslow County
The Non -Discharge Permitting Unit has completed a preliminary engineering review of the subject application. Additional
information is required before we can continue our review. Please address the following by January 29, 1999:
1. Please include a copy of the NRCS required specifications with your WUP.
2. Acreage for fields 2 and 7 are not shown on the map that was included in your permit application. Please
provide a clearer map that identifies (outlines or highlights) and shows the acreage for each field to be used
for waste application.
3. It is recommended that you include irrigation parameters in your WUP. Irrigation events are to be listed in
the WUP as the maximum application allowable for that soil type from the time the pumps are turned on
until the time they are shut off. It is currently recommended that total application amounts not exceed one
inch in any application event for any soil type. If your application rates need to be adjusted for the
application of animal waste, please have your Technical Specialist revise your WUP to reflect the
appropriate application amount per event. If the rates exceed the recommended one inch, please have your
Technical Specialist justify the increased application rate in the narrative of your WUP.
Please note that all WUP revisions must be signed and dated by both the owner and the technical specialist. Please
reference the subject permit application number when providing the requested information. All information should be signed,
sealed, and submitted in duplicate to my attention at the address below. The information requested by this letter must be
submitted on or before January 29, 1999 or the Division will return your application as incomplete in accordance with 15A
N.C.A.C. 2H .0200 and your facility will be considered to be operating without a permit.
Please be advised that operation of the subject animal waste management system without a valid permit is a violation of North
Cr
Carolina General Statute 143-215.1 and will subject you to the enforcement authority of the Environmental Management
Commission.
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

<< ,1e_
Application No. 67-0034
Oneal Gurganus
Page 2
If you have any questions regarding this request, please call the at [phone], extension 546.
Sincerely,
Susan Cauley
Environmental Engineer
Non -Discharge Permitting Unit
cc: Wilmington Regional Office, Water Quality
Permit File

State of North Carolina
Department of Environment,
Health and Natural Resources
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
November 13, 1996
Oneal and Lois Gurganus
Oneal & Lois Gurganus Farm
171 Futreal Rd
Richlands NC 28574
SUBJECT: Operator In Charge Designation
Facility: Oneal & Lois Gurganus Farm
Facility ID#: 67-34
Onslow County
Dear Mr. and Ms. Gurganus:
EDEHNR
Senate Bill 1217, An Act to Implement Recommendations of the Blue Ribbon Study
Commission on Agricultural Waste, enacted by the 1996 North Carolina General Assembly,
requires a certified operator for each animal waste management system that serves 250 or more
swine by January 1, 1997. The owner of each animal waste management system must submit a
designation form to the Technical Assistance and Certification Group which designates an
Operator in Charge and is countersigned by the certified operator. The enclosed form must be
submitted by January 1, 1997 for all facilities in operation as of that date. Failure to designate a
certified operator for your animal waste management system is a violation of 15A NCAC 2H
.0224 and may result in the assessment of a civil penalty.
If you have questions concerning operator training or examinations for certification, please
contact your local North Carolina Cooperative Extension Service agent or our office.
Examinations have been offered on an on -going basis in many counties throughout the state for
the past several months and will continue to be offered through December 31, 1996.
Thank you for your cooperation. If you have any questions concerning this requirement please
call Beth Buffington or Barry Huneycutt of our staff at 919I733-0026.
Sincerely,
Preston Howard, Jr., irector
Division of Water Quality
Enclosure
cc: Wilmington Regional Office
Water Quality Files
P.O. Box 27687.C
Raleigh, North Carolina 2761 1-7687 An Equal Opportunity/Affirmative Action Employer
Voice 919-715-4100 50% recycled/10% post -consumer paper

T..
Department of Environment, Health and Natural Re tirces4. _=
Division of Environmental Management
Water Quality Section
If the animal waste management system for your feedl� opeirat�11p.Tk
is designed to serve more than or equal to 100 head cif- catt;l4--,,,,
horses, 250 swine, 1,000 sheep, or 30,000 birds that 4�Q served
by a liquid waste system, then this form must be fille
mailed by December 31, 1993 pursuant to 15A NCAC 2H.0217
order to be deemed permitted by DEM. Please print clearly.
Farm Name: Oneal Gurganous
Route 1 Box 560
Richlands, NC 28574
Onslow Countv 919-324-2645(H)
Owner(s) Name:
Manager(s) Name:
Lessee Name:
Farm Location (Be as specific as possible rgoad, names p
direction, milepost, etc.): From Chinquapin, take) NC ill S to c'
Fountain, from Fountain continue on NC
.111 S and go 2.0 miles past Onslow Co.
line and turn Rt. onto SR 1209 and -go 0.5
mile to farm entrance on Lt. (TT=42 min.;
TD=28 miles)
Latitude/Longitude if known: QBSP # 24--Uzi-vz-zD
Design capacity of animal waste management system (Number and
type of confi ed animal s
Average animal population on the farm (Number and type of
animal (s), ,raised) :
Year Production Began: ASCS Tract No.:
Type .off' Wastq. Management System sed: _
Acres Available for Land Application of Waste:
Owner (s ) Signature (s) : �12G� Date:
Date:
l -7 _3 1 (Eugene Parker, Serviceman)

State of North Carolina
Department of Environment,
Health and Natural Resources 4 • 0
Division of Environmental Managementmwgaaw��'
James B..Hunt, Jr., Governor ok
Jonathan B. Howes, Secretary D FE F11•
A. Preston Howard, Jr., P.E., Director
March 21, 1994
Oneal Gurganous
Rt 1, Box 560
Richlands NC 28574
Dear Mr. Gurganous:
This is to inform you that your completed registration form required by the recently
modified nondischarge rule has been received by the Division of Environmental Management
(DEM), Water Quality Section.
On December 10, 1992 the Environmental Management Commission adopted a water
quality rule which governs animal waste management systems. The goal of the rule is for animal
operations to be managed such that animal waste is not discharged to surface waters of the state.
The rule allows animal waste systems to be "deemed permitted" if certain minimum criteria are
met (15A NCAC 2H .0217). By submitting this registration you have met one of the criteria for
being deemed permitted.
We would like to remind you that existing feedlots which meet the size thresholds listed
in the rule, and any new or expanded feedlots constructed between February 1, 1993 and
December 31, 1993 must submit a signed certification form (copy enclosed) to DEM by
December 31, 1997. New or expanded feedlots constructed after December. 31, 1993 must
obtain signed certification before animals are stocked on the farm. Certification of an
approved animal waste management plan can be obtained after the Soil and Water Conservation
Commission adopts rules later this year.
We appreciate you providing us with this information. If you have any question about
the new nondischarge rule, please contact David Harding at [phone].
enc:
Sincerely,
Steve Tedder, Chief
Water Quality Section
P.O. Box 29535, Raleigh. North Carolina 276264)535 7eiephone 919-733-7015 FAX'919-733-2496
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper 4