310678_HISTORICAL_20171231

NORTH CAROLINA
Department of Environmental Qual

Water Resources
ENVIRONMENTAL OVAL:TY
Murphy -Brown, LLC
Farm 3090
PO Box 856
Warsaw, NC 28398-0856
Dear Murphy -Brown, LLC:
REEEIVED/NWENR/M
JUL 2ff2016
July 22, 2016
Water Quality Regional
Operations Section
Wilmington Regional Office
PAT MCCRORY
Covcr:,ar
DONALD R. VAN DER VAART
S--y
S. JAY ZIMMERMAN
Subject: Certificate of Coverage No. AWS310678
Farm 3090
Swine Waste Collection, Treatment,
Storage and Application System
Duplin County
Jirwlor
In accordance with your July 19, 2016 request to change the operation type without exceeding the permitted
steady state live weight, we are hereby forwarding to you this Certificate of Coverage (COC) issued to
Murphy -Brown, LLC, authorizing the operation of the subject animal waste management system in
accordance with General Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management Plan
(CAWMP) for Farm 3090, located in Duplin County, with a swine animal capacity of no greater than the
following annual averages:
Wean to Finish: 8452
Feeder to Finish:
Boar/Stud-
Wean to Feeder:
Farrow to Wean:
Gilts:
Farrow to Finish:
Farrow to Feeder:
Other:
If this is a Farrow to Wean or Farrow to Feeder operation, there may be one boar for each 15 sows. Where
boars are unnecessary, they may be replaced by an equivalent number of sows. Any of the sows may be
replaced by gilts at a rate of 4 gilts for every 3 sows.
This COC shall be effective from the date of issuance until September 30, 2019, and shall hereby void
Certificate of Coverage Number AWS310678 dated October 1, 2014. Pursuant to this CDC, you are
authorized and required to operate the system in conformity with the conditions and limitations as specked
in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting and
maintaining the required monitoring data and operational information must be established for this facility.
Any increase in waste production greater than the certified design capacity or increase in number of animals
authorized by this COC (as provided above) will require a modification to the CAWMP and this COC and
must be completed prior to actual increase in either wastewater flow or number of animals.
Please read this COC and the enclosed State General Permit carefully. Please pay careful attention to the
record keeping and monitoring conditions in this permit. Record keeping forms are unchanged with this
General Permit. PIease continue to use the same record kepping fortes.
If your Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
state of North Carolina l Environmental Quality I Water Resalu=
1636 Mall service C ester I Raleigh, North C:arcima 27699-1636
919 807 6464

The issuance of this COC does not excuse the Pemvttee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Per MRCS standards a 100-foot separation shall be maintained between water supply wells and any lagoon,
storage pond, or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Program for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
in accordance with Condition U-22 of the General Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Tropical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You may
find detailed watch/warning information for your county by calling the Newport/Morehead City, NC
National Weather Service office at [phone], or by visiting their website at:
hM://www.weathcr.goy/mhx/
This facility is located in a county covered by our Wilmington Regional Office. The Regional Office staff
may be reached at 910-796-7215. If you need additional information concerning this COC or the General
Permit, please contact the Animal Feeding Operations Program staff at [phone].
Sincerely,
for`V°'"' .
S. Say Zimme P.G.
Director, Division of Water Resources
cc: (Certificate of Coverage only for all ccs)
Wilmington Regional Office, Water Quality Regional Operations Section
Duplin County Health Department
Duplin County Soil and Water Conservation District
WQROS Central Files (Permit No. AWS310678)

Murphy -Brown LLc
May 7, 2014
NCDENR, DWR
Wilmington Regional Office
127 Cardinal Drive Extension
Wilmington, NC 28405
Subject: Burial Site Map for
Farm 3090; Fac. No.: 31-678
Duplin County
PO Drawer 856
2822 Hwy. 24 West
Warsaw, NC 28398
Tet 910-293-3434
Fax:[phone]
t"'AY082014
3Y
Enclosed please find a copy of the map of the burial site for the above -mentioned facility where during
September — December 2013, 74 nursery and 57 finishers were buried in Dead Hole B in accordance with
the facility's CAWMP and the NCDA&CS Veterinary Division's Statutes and regulations. This was due to
above normal mortality at this facility. Please place in the appropriate files.
1f you have any questions regarding this matter, please do not hesitate to call me at [phone] ext.
5363.
Sincerely,
Kevin Weston, CID
Environmental Compliance
Cc: Murphy -Brown, LLC Files

3090 Dead Hole A (Max Depth
99063 FARM 36903 BOC; 99 FINISF
�t
1
1 _
4 k
090 Dead Hole B (MaxIepth 60")

Murphy -Brown, LLC
Grower(s):
Farm Name:
3/11 /2009
NUTRIENT UTILIZATION PLAN
Murphy -Brown, LLC
3090; Fac. No.: 31-678
County: Du lin
Farm Capacity.
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish 7200
Storage Structure:
Storage Period:
Application Method:
Anaerobic Lagoon
>180 days
Irrigation
2822 Hwy 24 West
P.O. Box 856
Warsaw, NC 28398
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems. RE:CEJTV�+
6. To maximize the value of the nutrients for crop production and to reduce the pot"?'
2 8 2003
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting theBVe or
disking will conserve nutrients and reduce odor problems.
1 of 11 RECEIVED 1 DENR 1 DWQ
Agiiifpr ProtPrtinn Section
MAY 14 2009

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, W, tons, etc.):
Capacity Type Waste Produced per Animal Total
Farrow to Wean
3212 gallyr
gallyr
Farrow to Feeder
4015 gallyr
gallyr
Farrow to Finish
10585 gallyr
gallyr
Wean to Feeder
223 gallyr
gallyr
7200
Feeder to Finish
986 gallyr
7,099,200 gallyr
Total 7,099,200 gallyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (Ibs):
Capacity Type Nitrogen Produced per Animal Total
Farrow to Wean
5.4 Ibslyr
Ibslyr
Farrow to Feeder
6.5 Ibslyr
Ibslyr
Farrow to Finish
26 Ibslyr
Ibslyr
Wean to Feeder
0.48 Ibslyr
Ibslyr
7200
Feeder to Finish
2.3 Ibslyr
16,560 lbslyr
Total 16,560 Ibslyr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 38.21
Total N Required 1 st Year: 13345.25
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops: 13,345.25
Total Nitrogen Produced by Farm: 13,082.40
Nitrogen Balance for Crops: (262.85)
`See Additional Comments on Page 7
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2of11

Reception.•
Tract Hydrant Tr-rigated soHl -Ist Cr-O-P Time to Ist Crop lst Crop Lbs NJAc Lbs N ToW lbs N
Acreage Type Code .... .. ARE[y__. Yield lbs NlUnit Residual.._ lAc UtiiJzEd-
-
3(a) of 11

Tract Field Irrigated Soil I st
Acreage Type— , 'ssrer rs• ,..,
3(b) of 11

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code Crop
A Barley
B Hybrid Bermudagrass - Grazed
C Hybrid Bermudagrass - Hay
D Corn - Grain
E Corn - Silage
F Cotton
G Fescue - Grazed
H Fescue - Hay
I Oats
J Rye
K Small Grain - Grazed
L Small Grain - Hay
M Grain Sorghum
N Wheat
O Soybean
P Pine Trees
Q Matua
Lbs N utilized 1 unit yield
1.6 lbs N 1 bushel
50 lbs N / ton
50 lbs N 1 ton
1.25 lbs N / bushel
12 lbs N / ton
0.12 lbs N 1 lbs lint
50 lbs N I ton
50 lbs N / ton
1.3 lbs N 1 bushel
2.4 lbs N / bushel
50 lbs N / acre
50 lbs N 1 acre
2.5 lbs N 1 cwt
2.4 lbs N / bushel
4.0 lbs N 1 bushel
40 lbs N 1 acre 1 yr
50 lbs N 1 ton
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4ot11

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PANT rlanimal Farm Totallyr
Farrow to Wean 0.84
Farrow to Feeder 1
Farrow to Finish 4,1
Wean to Feeder 0.072
7200 Feeder to Finish 0.36 2592
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 2592 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 12960 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 43 acreas of land. if you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 103.68 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
`This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 11

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract
Hydrant
Type
Crop
inlhr
* inches
UN
1
AuB
C
0.6
1
UN
2
AuB
C
0.6
1
UN
3
AuB
C
0.6
1
UN
4
BnB
C
0.75
1
UN
5
AuB
C
0.6
1
UN
6
BnB
C
0.75
1
UN
7
BnB
C
0.75
1
UN
8
BnB
C
0.75
1
6of11

Additional Comments:
This plan revised to show the corrected location of Zones 4 & 5.
The Amounts of Waste and Plant Available Nitrogen Produced per year as
shown in the tables on page 2 of this plan are the typical amounts that are
used in the absence of actual "On -Farm" records. However, site specific data
from 1999-2002 and the NCCES Publication AG-439-42 was used to determine
the Average Amounts of Waste and Plant Available Nitrogen produced at this
facility. The number used in this plan for Total Lbs. PAN/Year is 20% hiaher
than the Total Lbs. PAN/Year generated by using the publication.
Attached is a consolidation of that data.
Producer may substitute small grain for the matua if desired. The application
rates and times are the same for either.
7of11

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: 3090; Fac. No.: 31-678
Owner: Murphy -Brown, LLC
Manager: David Nordin
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
Uwe understand that 1 must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Murphy -Brown, LLC
Signature:
Name of Manager (if different from owner)
Signature:
David Nordin
Date
Date
Name of Technical Specialist:
M. Kevin Weston
Affiliation:
Murphy -Brown, LLC
Address:
2822 Hwy 24 West, PO Box 856
Warsaw, NC 28398
Telephone:
[phone]
Signature:
Dat
8 of 11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, helshe shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recievinq crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
Yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, MRCS Field Office Technical Guide Standard 393 - Filter Strips).
Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
5 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen_
9 of 11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
10 of 11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
11 of 11

BOC
Farm 3090
PWl Gel.
Spray
Fields
Zone #
Acres
eZone 8
Scale: 1"=300'
1
2
7.42
3.56
3
3.3 3
4
8.93
5
4.23
5
9.59
7
0.42
' Cwd.
8
0.73
P>I Cod.
•
Total
38.21
Zone 7
•
• ' •
• al CIrd.
Pwl Cid.
-
•Zone
6� ,
law
-
Pere Clyd.
. - •
• -
,
• /
e.
^ O� Pal CJrc4
Zone 4 •/;
'�.
.
-
rl•
'
m
zone 5
KIP
rely 0
I7 -y
} „ -
ert Card.
8 . 002919 e
• -
��RIT-
Zone 3

Michael F. Easley, Governor
William G. [toss Jr.. Secretary
North Carolina Department of Environment and Natural Resources
Coleen H. Sullins, Director
Division of Water Quality
July 1, 2007 77 ' IVED
Murphy -Brown, LLC JUN 2 6 2007
Farm 90
PO Box 856 by,
Warsaw, NC 28398
Subject: Certificate of Coverage No. AWS310678
Farm 90
Animal Waste Management System
Duplin County
Dear Murphy -Brown, LLC:
In accordance with your application received on 11-Jun-07, we are hereby forwarding to you this
Certificate of Coverage (COC) issued to Murphy -Brown, LLC, authorizing the operation of the subject
animal waste management system in accordance with General Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for the Farm 90, located in Duplin County, with an animal capacity of no greater than the
following swine annual averages:
Wean to Finish: 0 Feeder to Finish: 7200 Boar/Stud: 0
Wean to Feeder: 0 Farrow to Wean: 0 Gilts: 0
Farrow to Finish: 0 Farrow to Feeder: 0
If this is a Farrow to Wean or Farrow to Feeder operation, there may also be one boar for each 15 sows.
Where boars are unneccessary, they may be replaced by an equivalent number of sows. Any of the sows
may be replaced by gilts at a rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009 and replaces the NPDES
COC issued to this facility with an expiration date of July 1, 2007. You are required to continue
conducting annual surveys of sludge accumulation in all lagoons at your facility; the one-year extension
in Condition III.19 does not apply.
Pursuant to this COC, you are authorized and required to operate the system in conformity with the
conditions and limitations as specified in the General Permit, the facility's CAWMP, and this COC. An
adequate system for collecting and maintaining the required monitoring data and operational information
must be established for this facility. Any increase in waste production greater than the certified design
capacity or increase in number of animals authorized by this COC (as provided above) will require a
modification to the CAWMP and this COC and must be completed prior to actual increase in either
wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Enclosed for your convenience is
a package containing the new and revised forms used for record keeping and reporting. Please pay
careful attention to the record kepping and monitorin conditions in this ermit.
Aquifer Protection Section 1636 Mail Service Center
Internet www.ncwaterauality.ore Location: 2728 Capital Boulevard
An Equal opportunity/Affirmative Action Employer— 50% Recyded/10% Post Consumer Paper
Ial�ellrrCarolina
Amm-rally
Raleigh, NC 27699-1636 Telephone: [phone]
Raleigh, NC 27604 Fax 1: [phone]
Fax 2: [phone]
Customer Service: [phone]

If your Waste Utilization Plan has been developed based on site -specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 02T .01 I I (c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100-foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Per 15A NCAC 02T .1306, any containment basin, such as a lagoon or waste storage structure, shall
continue to be subject to the conditions and requirements of the facility's permit until closed to NRCS
standards and the permit is rescinded by the Division.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-2I5.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Wilmington Rea oval Office. The Regional Office
Aquifer Protection staff may be reached at 910-395-3900. If you need additional information concerning
this COC or the General Permit, please contact the Animal Feeding Operations Unit staff at (919) 733-
3221.
Sincerely,
for Coleen H. Sullins
Enclosures (General Permit AWG100000, Record Keeping and Reporting Package)
cc: (Certificate of Coverage only for all cc's)
Duplin County Health Department
Duplin County Soil and Water Conservation District
Wilmington Regional Office, Aquifer Protection Section
AFO Unit Central Piles
Permit File AWS310678

MurphrBrown LLL
Murphy Brown East
December 23, 2008
Kevin Rowland
NCDENR — Division of Water Quality
127 Cardinal Drive Extension
Wilmington, NC 28405
RE: Hydraulic Overload on farm 30903
Facility # 31-678
Post Office Box 856
Warsaw, NC 28398
BY:
CmIVP,D
DEC 2 9 ?Goa
Dear Mr. Rowland,
This letter is notifying you of a hydraulic overload on farm 30903 on field 4
As you are aware, Murphy Brown LLC has implemented a computer based record keeping
system (LWMS) that is used to keep irrigation records. As well as a record keeping tool, this system
was designed so that it would serve as a checks and balance between the handheld computer and the
operator in the field. For example: When a operator in the field is making preparations to begin an
irrigation event, he will calculate how long he may run the event, keeping in mind the PAN applied and
gallons applied per acre. After he has calculated the length of the event, it is entered into a handheld
computer which will also calculate what PAN will be applied and the amount of water that will be
applied per acre, if the event is run for the time entered. If a nutrient or hydraulic over application will
occur from the planned event, the handheld will not accept the given data forcing the technician to
change the length of the event.
On December 16, 2008 during a routine Soil and Water Inspection, Will Burke, John College
and Patrick Fussell found an irrigation event that had exceeded 27,154 gallons per acre. The event
occurred on farm 30903 in zone 4 that occurred on 10-29-08 on the small grain overseed crop, which
applied 30,765 gallons per acre. This was noted in their inspection report.
The LWMS system should have not allowed this event to be saved in the system. After
investigating this event, and making sure their was no error on the part of the operator who entered the
event, it was discovered that there was a program error in the LWMS system that allowed the operator
to enter the event that allowed the hydraulic over application to occur without notifying him of the over
application. The LWMS system should have forced him to adjust his application times before he began
the event.
Murphy Brown is continually striving for environmental excellence, and the implementation of
the LWMS system is helping us meet this goal. This minor error in the program is very insignificant
when you consider the vast number of irrigation events that have been successfully entered since we
began using the system in March of this year. Even though there is not a great chance of this being a
problem in the future, we are currently having Taylor Data Systems correct the problem with the
program to ensure this will not be repeated in the future. In addition to correcting the program error,
training with the operator that entered the event has already taken place, and training with all operators
in the field to inform them of the problem is scheduled.

• Page 2
If I can be of any further assistance, please feel free to contact me.
Sincerely, /
Greg Carr
Environmental Resource Specialist
Murphy -Brown LLC
[phone] ext. 232
Attachments: IRR2 for 30903 Zone 4
December 23, 2008

Form ESC-IRR-2
Field # 04
Field Size (acres) = (A) 4.23
Farm Name 30903
Farm Owner / OTC Murphy Brown, LLC
Crop Number
Crop Type SMALL GRAIN 1st
Cal. (1) Col. (2) Col. (3) Cal. (4) Col. (5)
Date Start Time End Time Total Min Equipment
mnifdd/yr (hr:min) (hr:min) (3)-(2)
10/29/08 8:20 am 11:20 am 180 30903-04
Lagoon Liquid Irrigation Field Record Dore 12/19/2008
One Form for Each Field Per Crop Cycle
From Animal Waste Management Plan
Owner I OTC's Address 1020 CARLTON CHAPEL CHURCH ROAD
WARSAW, NC 28399
Owner / OTC's Phone # [phone]
Recommended PAN 50.00
Recommended PAP 0.00
Loading (LB/acre) = (B)
Col. (6)
Cal. (7)
Col, (a) Col. (9) Cal. (10)
Col. (111
Cal_ (12)
Flow
Total Volume
Volume Per Waste Analysis * PANIPAP Applied
Nitrogen/Phosphorus
Operator
Rate
(gallons)
Acre (gal/ac) PAN/PAP (lblac)
Balance •
Name/ Inspect Time
(gatslmin)
(4) X (6)
71(A) (lb11000 gat) (8)X(9) divided by 1,000
(lblac)(B) - 10
723.00
130,140
30,765.96 1.50 46.15
3.85
DEDWARDS / ALL
0.00 0.00
0,00
(9) NCdA Waste Analysis or Equivalent or NRCS Estimate, Technical Guide Section.
(11) Enter the value received by subtracting column (10) from (B). Continue
subtracting column (1a) from column (11) following each Irrigation event,
Owner: Murphy Brown LLC
Certiried Operator. Murphy Brown LLC
Page 1 of 1

J
WASTE UTILIZATION PLAN
NPOES PERMIT itENEWAL - 2007
REGIONAL OFFICE - APS
❑ ASHEVILLE
❑ FAYETTEVILLE
❑ MOORESVILLE
❑ RALEIGH
❑ WASHINGTON
ZV WILMINGTON
❑ WINSTON-SALEM
FARM NO: .Sl- 06 7cf"'

0 `
l
ANIMAL FACILITY ANNUAL CER'I`IFICA'TX FO
DI
Certificate of Coverage or Permit Number NCA231678 County Duplin Year 2003
Facility Name (as shown on Certificate of Coverage or Permit) Farm 90
Operator in Charge for this Facility Bradley Herring Certification # 26545
Land application of animal waste as allowed by the above permit occurred during the past calendar year
X Yes No. If NO, skip Part I and Part II and proceed to the certification. Also, if animal waste was
generated but not land applied, please attach an explanation on how the animal waste was handled.
Part I: Facility Information:
1. Total number of application Fields []or Pulls [please check the appropriate box) in the Certified Animal
Waste Management Plan (CAWMP): F-N/A/P-8 Total Useable Acres approved in the CAWMP
38.21
2. Total number of Fields ❑ or Pulls N?I(p?ease check the appropriate box) on which land application
occurred during the year: F-N/A/P-8 Total Acres on which waste was applied 38.21
3. Total pounds of Plant Available Nitrogen (PAN) applied during the year for all application sites:
9,046.10
4. Total pounds of Plant Available Nitrogen (PAN) allowed to be land applied annually by the CAWMP and
the permit: 13.345.25
5. Estimated amount of total manure, litter and process wastewater sold or given to other persope6 men
off site during the year ❑ tons ❑ or gallons (please check the appropriate box) x 1 VED
6. Annual average number of animals by type at this facility during the previous year: MAR a 1 2004
N/A Information provided by Mav 1, 2004 i"ATEnL.r
7.Largest and smallest number of animals by type at this facility at any one time during the previous�e�
Largest N/A
Smallest NIA
(These numbers are for informational purposes only since the only permit limit on the number of animals
at the facility is the annual average numbers)
S. Facility's Integrator if applicable: L-L.C_
Part It: Facility Status:
IF THE ANSWER TO ANY STATEMENT BELOW IS "NO", PLEASE PROVIDE A WRITTEN
DESCRIPTION AS TO WHY THE FACILITY WAS NOT COMPLIANT, THE DATES OF ANY NON
COMPLIANCE, AND EXPLAIN CORRECTIVE ACTION TAKEN OR PROPOSED TO BE TAKEN TO
BRING THIS FACILITY BACK INTO COMPLIANCE.
Only animal waste generated at this facility was applied to the permitted sites during peYes ❑ No
the past calendar year.

T
•2.
The facility was operated in such a way that there was no direct runoff of waste from
O�Iyes ❑ No
the facility (including the houses, lagoons/storage ponds and the application sites) during
the past calendar year.
3.
There was no discharge of waste to surface water from this facility during the past
®des ❑ No
calendar year.
4.
There was no freeboard violation in any lagoons or storage ponds at this facility during
❑ Yes Er No
past calendar year. PA
5.
There was no PAN application to any fields or crops at this facility greater than the
❑'Yes ❑ No
levels specified in this facility's CAWMP during the past calendar year.
6.
All land application equipment was calibrated at least once during the past calendar year.
Yes ❑ No
7.
Sludge accumulation in all lagoons did not exceed the volume for which the lagoon
was designed or reduce the lagoon's minimum treatment volume to less than the volume
❑ Yes ❑ No
for which the lagoon was designed_ _ 3
8.
*NIA Will be done and on fife by April 24, 2004
A copy of the Annual Sludge Survey Form for this facility is attached to the Certification.
❑ Yes ❑ No
*NIA Will be done and on tale by April 24, 2004
9.
Annual soils analysis were performed on each field receiving animal waste during the
[,'Yes ❑ No
past calendar year.
10.
Soil pH was maintained as specified in the permit during the past calendar Year?
Efyes ❑. No
11.
All required monitoring and reporting was performed in accordance with the facility's
DYes ❑ No
permit during the past calendar year.
12.
All operations and maintenance requirements in the permit were complied with during
❑ Yes EfrNo
the past calendar year or, in the case of a deviation, prior authorization was received
from the Division of Water Quality.
II
Crops as specified in the CAWMP were maintained during the past calendar year on all
D Yes ❑ No
sites receivin_tr animal waste and the crops grown were removed in accordance with
the facility's permit.
14.
All buffer requirements as specified on the permit and the CAWMP for this facility were
B;� Yes ❑ No
maintained during each application of animal waste during the past calendar year.
"I certify under penalty of law that this document and all attachments were prepared under my direction or
supervision in accordance with a system designed to assure that qualified personnel properly gather and
evaluate the information submitted. Based on my inquiry of the person or persons who manage the system, or
those persons directly responsible for gathering the information, the information submitted is, to the best of my
knowledge and belief, true, accurate, and complete_ I am aware that there are significant penalties for
submitting false information, including the possibility of fines and imprisonment for knowing violations."
ame and Title (type or print)
Signature of Operator in Charge
(if different from Permittee)
Date
Date

ANIMAL FACILITY ANNUAL CERTIFICATION FORM
AMENDMENT
Year: 2003
Permit Number: NCA231678
County: Duplin
Facility #: 31-678
Facility Name: Farm 90
6. Annual average number of animals by type at this facility during the
previous year:
Wean — Feeder:
Feeder — Finish: 7,013
Farrow — Wean:
Farrow — Feeder:
Boar Stud:
Wean - Finish:
Commercial Nursery_
Total Average: 7,013

Murphy -Brown LLC p0 Drawer 856
2822 Hwy. 24 Vilest
6 �t Warsaw, NC 28398
Tel: [phone]
aLFax 914293-3138
Mr. Shiver,
The following farms within the Murphy -Brown, LLC system had plan
amendments made to extend pumping windows. The plan amendments are attached for
each farm.
Farm Name
Facifily Number
Volunteer
31-613
3501, 3102
31-514
3112
31-401
3090
31-678
2529
31-740
2704, 2706
31-375
If there are any questions please let me know.
Regards,
Todd Rowe, CCA
Agronomist
Murphy -Brown, LLC

CAWMP AMENDMENT
3090
This amendment is intended to extend the pumping window on Bermuda through
September 15`h, 2003. The crop on the farm was found to be in good health and at a stage
that is receptive to Nitrogen application. Croremoval from the fields is expected to be
sufficient to receive PAN until September 15` , 2003. Warm temperatures and good
weather will contribute to growth and uptake of nutrients by the crop.
L ke 4,41 74a,l0 6 6
Owner, Murphy -Brown, LLC Date
Z�Lj /a bp
Manager Date
Technical Specialist Date

gfce��f�-D
qI I
PLAN OF ACTION(Poa) FOR HIGH FREEBOARD AT ANIMAL FACILITIES
Facility Number: 31-678 County: Duplin
Facility Name: 3090
Certified Operator Name: iD rl-I%V Operator Number: a�SyS
1. Current liquid level(s) in inches as measured from the current liquid level in the lagoon to the
lowest point on the top of the dam for lagoons without spillways; and from the current liquid level
in the lagoon to the bottom of the spillway for lagoons with spillways.
Lagoon i Lagoon 2 Lagoon 3 Lagoon 4 Lagoon 5
Lagoon Name/ID: 3090
Spillway(Y or N): N
Level(inches): 18
2. Check all applicable items
Liquid level is within the designed structural freeboard elevations of one or more structures.
Five and 30 day Plans of Action are attached. Hydraulic and agronomic balances are
within acceptable ranges.
X Liquid level is within the 25 year 24 hour storm elevations for one or more structures. A
30 day Plan of Action is attached. Agronomic balance is within acceptable range.
Waste is to be pumped and hauled to off site locations. Bolume and PAN content of waste
to be pumped and hauled is reflected in section III tables. Included within this plan is a list
of the proposed sites with related facility numbers, number of acres and receiving crop
information. Contact and secure approval from the DWO prior to transfer of waste to a site
not covered in the facility's CAWMP.
Operation will be partially or fully depopulated.
*Attach a complete schedule with corresponding animal units and dates fro depopulation
*if animals are to be moved to another permitted facility, provide facility number, lagoon
freeboard levels and herd population for the receiving facility
3. Earliest possible date to begin land application of waste:
I hereby certify that I have reviewed the information listed above and included within the
attached Plan of Action, and to the best of my knowledge and ability, the information is
accurate and correct.
//d�uo ���., �1c'. / yam; / 9�a -2
L�[ - ��yt, �' c� �!"��i� Phone:
"Facility Owner/Manag r (print)
/MBL-k l�2�1�,L Date: 7 ,- 4�
Facility Owner/Manager (signature)

PLAN OF ACTION (PoA) FOR HIGH FREEBOARD AT ANIMAL FACILITIES
30 DAY DRAW DOWN PERIOD
I. TOTAL PAN TO BE LAND APPLIED PER WASTE STRUCTURE
1. Structure Name/identifier (ID): 13090
2. Current liquid volume in 25 yr.124 hr. storm storage & structural freeboard
a. current liquid level according to marker 18.0 inches
b. designed 25 yr./24 hr. storm & structural freeboard 19.0 inches
c. line b - line a (inches in red zone) = 1.0 inches
d. top of dike surface area according to design
(area at below structural freeboard elevation) 1 151986 ft2
e. line 02 x line d x 7.48 gallons/ft3 94738 gallons
3. Projected volume of waste liquid produced during draw down period
f. temporary storage period according to structural design 180 days
g. volume of waste produced according to structural design 237369 ft3
h. current herd # 7200 certified herd # 7200
actual waste produced = current herd # x line g =
certified herd #
i. volume of wash water according to structural design
j. excess rainfall over evaporation according to design
k. (lines h + i + j) x 7.48 x 30 days/line f=
4. Total PAN to be land applied during draw down period
I. current waste analysis dated 1 06/10/2003
m. ((lines e + k)11000) x line I =
REPEAT SECTION I FOR EACH WASTE STRUCTURE ON SITE.
(Click on the next Structure tab shown below)
237369 ft3
®W
91875 fP
410458 gallons
3.40 Ibs11000 gal.
1717.7 lbs. PAN
PoA (30 Day) 2/21100

II. TOTAL POUNDS OF PAN STORED WITHIN STRUCTURAL FREEBOARD AND/OR 25 YR.124
HR. STORM STORAGE ELEVATIONS IN ALL WASTE STRUCTURES FOR FACILITY
1.
Structure ID: 3090
line m = 1717.7 lb PAN
2.
Structure ID:
line m =
lb PAN
3.
Structure ID:
line m =
lb PAN
4.
Structure ID:
line m =
lb PAN
5.
Structure ID:
line m =
lb PAN
6.
Structure ID:
line m =
lb PAN
n.lines 1+2+3+4+5+6= 1717.7lbPAN
Ill. TOTAL PAN BALANCE REMAINING FOR AVAILABLE CROPS DURING 30 DAY DRAW DOWA
PERIOD_ DO NOT LIST FIELDS TO WHICH PAN CANNOT 13E APPLIED DARING THIS 3n DAY PERIOD
o. tract #
p. field #
q. crop
r. acres
s. remaining IRR
2 PAN balance
(Iblacre)
t. TOTAL PAN
BALANCE FOR
FIELD (lbs.)
column r x s
u. application window'
5
Bermuda
8.93
147.10
1313.E
Mar -Oct
3
Bermuda
3.33
146.40
487.5
Mar -Oct
State current crop ending application date or next crop application beginning date for available
receiving crops during 30 day draw down period.
v. Total PAN available for all fields (sum of column t) = 1801.1 lb. PAN
IV. FACILITY'S PoA OVERALL PAN BALANCE
w. Total PAN to be land applied (line n from section II) = 1717.7 lb. PAN
PoA (30 Day) 2/21/00

x. Crop's remaining PAN balance (line v from section 111) = 1801.1 lb. PAN
y. Overall PAN balance (w - x) _ -83 lb. PAN
Line y must show as a deficit. If line y does not show as a deficit, list course of action here including pump and
haul, depopulation, herd reduction, etc. For pump & haul and herd reduction options, recalculate new PAN
based on new information. If new fields are to be included as an option for lowering lagoon level, add these
fields to the PAN balance table and recalculate the overall PAN balance. If animal waste is to be hauled to
another permitted facility, provide information regarding the herd population and lagoon freeboard levels at the
receiving facility.
Irrigation onto existing spray fields will continue as weather and field conditions permit. Additional land is
available for pumping if needed.
PoA (30 Day) 2/21/00

Lagoon Freeboards
Subject: Lagoon Freeboards
Date: Mon, 14 Jul 2003 16:29:01 -0400
From: "Nordin, David"<DavidNordin@brownsofcarolina_com>
To: "'[e-mail]"' <[e-mail]>
CC: "'John. [e-mail]"' <[e-mail]>,
"' Rick. [e-mail]"' <[e-mail]>
Freeboard Levels - Murphy Brown LLC Kenansville Division - 7/14103
Farm Facility#
2147 31 - 468
Batchelor 31 - 563
Turner Sow 31 - 57
3620
31 - 400
Scott
31 - 5
Envirotech
31 - 177
3090
31 - 678
2149
31 - 567
2704
31 - 375
Lagoon Level
17 inches
A - 17 inches
B - 17 inches
31 - 14 inches
S2 - 14 inches
S3 - 17 inches
18 inches
15 inches
S1 - 18.5 inches
18 inches
16 inches
16 inches
2706 31 - 375 10 inches In addition to a 30 day PoA, a 5 day PoA will be submitted for
this farm.
If you have any further questions, please call me at 910 - 296 - 3731.
Thank You
David Nordin
Land & Nutrient Management
Murphy Brown LLC
Kenansville Division
1 of 1 7/16/2003 3:02 PM

Murphy -Brown, LLC
Grower(s):
Farm Name:
11 /25/20 ,0- 2822 Hwy 24 West
P.O. Box 856
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Brown's of Carolina
BOC #90
County: Duplin
Farm Capacity:
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish 7200
Storage Structure:
Storage Period:
Application Method:
Anaerobic Lagoon
>180 days
Irrigation
RECEIVED / DFNR 1 DWa
AQUj;7FR PRnTFrTli]N SECT10N
DEC 2 72006
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner. -
Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8 M800107030021

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, fta, tons, etc.):
Capacity Type Waste Produced per Animal Total
Farrow to Wean
3212 gallyr
gallyr
Farrow to Feeder
4015 gallyr
gallyr
Farrow to Finish
10585 galyr
gallyr
Wean to Feeder
223 gallyr
galyr
7200
Feeder to Finish
986 gallyr
7,099,200 gallyr
Total 7,099,200 gallyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs):
Capacity Type Nitrogen Produced per Animal Total
Farrow to Wean
5.4 Ibslyr
Ibslyr
Farrow to Feeder
6.5 Ibslyr
Ibslyr
Farrow to Finish
26 Ibslyr
Ibslyr
Wean to Feeder
0A8 Ibslyr
Ibslyr
7200
Feeder to Finish
2.3 Ibslyr
16,560 Ibslyr
Total 16,560 1 bslyr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 38.21
Total N Required 1st Year: 13345.25
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops: 13,345.25
Total Nitrogen Produced by Farm: 13,082.40 '
Nitrogen Balance for Crops: (262.85)
'See Additional Comments on Page 7
The following table describes the spe6tications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
M1300107030022
2of8

g0c..._s0
dC'op Time to 2nd Crop 2nd Crop Lbs NiAc Lbs N Total lbs
.,.
��
i
MB00107030023
3(a) of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. 1n fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized / unit yield
A
Barley
1.6 lbs N 1 bushel
B
Hybrid Bermudagrass - Grazed
50 lbs N / ton
C
Hybrid Bermudagrass - Hay
50 lbs N / ton
D
Corn - Grain
1.25 lbs N / bushel
E
Corn - Silage
12 lbs N / ton
F
Cotton
0.12 lbs N / lbs lint
G
Fescue- Grazed
50 lbs N / ton
H
Fescue- Hay
50 lbs N 1 ton
1
Oats
1.3 lbs N 1 bushel
J
Rye
2.4 lbs N / bushel
K
Small Grain - Grazed
50 lbs N 1 acre
L
Small Grain - Hay
50 lbs N 1 acre
M
Grain Sorghum
2.5 lbs N / cwt
N
Wheat
2.4 lbs N / bushel
O
Soybean
4.0 lbs N / bushel
P
Pine Trees
40 lbs N / acre / yr
Q
Matua
50 lbs N / ton
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste_
MB00107030024
4 of 8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PANlyrlanimal Farm Totallyr
Farrow to Wean 0.84
Farrow to Feeder 1
Farrow to Finish 4.1
Wean to Feeder 0.072
7200 Feeder to Finish 0.36 2592
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 2592 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation fisted above.
If you remove the sludge every 5 years, you will have approximately 12960 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 43 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 103.68 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
'This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 8 MB00107030025

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract
Hydrant
Type
Crop
inlhr
* inches
UN
1
AuB
C
0.6
1
UN
2
AuB
C
0.6
1
UN
3
AuB
C
0.6
1
UN
4
AuB
C
0.6
1
UN
5
BnB
C
0.75
1
UN
6
BnB
C
0.75
1
UN
7
BnB
C
0.75
1
UN
8
BnB
C
0.75
1
MB00107030026
6 of 8

Additional Comments:
This plan revised to show wetted acres by hvdrant.
The Amounts of Waste and Plant Available Nitrogen Produced per year as
shown in the tables on page 2 of this plan are the typical amounts that are
used in the absence of actual "On -Farm" records. However, site specific data
from 1999-2002 and the NCCES Publication AG-439-42 was used to determine
the Average Amounts of Waste and Plant Available Nitrogen produced at this
facility. The number used in this plan for Total Lbs. PAN/Year is 20% higher
than the Total Lbs. PANNear generated by using the publication.
Attached is a consolidation of that data.
Producer may substitute small grain for the matua if desired. The application
rates and times are the same for either.
MS00107030027
7of8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: BOC ##90
Owner: Brown's of Carolina
Manager: David Nordin
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
Me understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner:
Signature:
Brown's of Carolina
Name of Manager (if different from owner):
Signature:
David Nordin
// �2 5
Date
Name of Technical Specialist: M. Kevin Weston
Affiliation: Murphy -Brown, LLC
Address: 2822 Hwy 24 West, PO Box 856
Warsaw, NC 28398
Telephone: [phone]
Signature: Ijr�j, st.� �� ///J' e
MB00107030028
8of8

If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is -necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, . the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 2H .0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per MRCS standards a 100 foot separation
shall be maintained between water supply wells and any lagoon or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C, the Clean Water Act and 40 CFR 122.41 including civil penalties, criminal
penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual NPDES Permit by contacting the staff member listed below for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Wilmington Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Sue Homewood at [phone] ext. 502.
Sincerely,
U
for Alan W- Klimek, P.E.
Enclosures (General Permit NCA200000, Record Keeping and Reporting Package)
cc: (Certificate of Coverage only for all cc's)
Duplin County Health Department
Wilmington Regional Office, Water Quality Section
Duplin County Soil and Water Conservation District
Permit File NCA231678
Permit File AWS310678
NDPU Files

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of EmAronment and Natural Rescurces
Alan W. Klimek, P. E., Director
Division of Water Quality
April 9, 2003
Brown's of Carolina, Inc.
Farm 90
PO Box 759
Rose Hill NC 28458
Subject: Certificate of Coverage No. NCA231678
Farm 90
Swine Waste Collection, Treatment,
Storage and Application System
Duplin County
Dear Brown's of Carolina, Inc.:
On March 14, 2003, the North Carolina Division of Water Quality (Division) issued an NPDES General
Penmit for swine facilities. The General Per.:nt was :-.sued to enable sine facilities in Norm Carolina to
obtain coverage under a single permit that addresses both State and Federal requirements.
In accordance with your application received on February 13, 2003, we are hereby forwarding to you this
Certificate of Coverage (CDC) issued to Brown's of Carolina, Inc., authorizing the operation of the
subject animal waste collection, treatment, storage and land application system in accordance with
NPDES General Permit NCA200000. The issuance of this COC supercedes and terminates your COC
Number AWS310678 to operate under State Non -Discharge Permit AWGI00000.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Farm 90, located in DupiinCounty, with an animal capacity of no greater than an
annual average of 7200 Feeder to Finish swine and the application to land as specified in the facility's
Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or Farrow to Feeder
operation, there may also be one boar for each 15 sows. Where boars are unneccessary, they may be
replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a rate of 4 gilts
for every 3 sows
The COC shall be effective from the date of issuance until July I, 2007. Pursuant to this CDC, you are
authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this CDC (as provided above) will require a modification to the CAWMP and
this CDC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this CDC and the enclosed General Permit. Since this is a new joint State and
Federal general permit it contains many new requirements in addition to most of the conditions contained
in the current State general permit. Enclosed for your convenience is a package containing the new and
revised forms used for record keeping and reporting. Please_ pay careful attention to the record keeping
and monitoring conditions in this permit. The Devices to Automatically Sto 71Irri.gation Events Form
must be returned to the Division of Water Ouality no later than 120 days following receipt of the
Certificate of Covera e. The Animal Facility Annual Certification Form must be completed and returned
to the Division of Water Quality by no later than March 1st of each year.
A
�r
Non -Discharge Permitting Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
Customer Service Center
An Equal Opportunity Action Employer
Internet httpJ/h2o.enr,state.nC.us/ndpu
Telephone [phone] Fax [phone]
Telephone [phone]
50% recycled/1 0% post -consumer paper

Brown's of Carolina • 12/1 /00 Hwy 24 East
Warsaw, NC 28398
3NUTRIENT UTILIZATION PLAN _
Grower(s):
Farm Name:
Brown's of Carolina
BOC #90
County: Duplin
Farm Capacity.
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish 7200
Storage Structure:
Storage Period:
Application Method:
Anaerobic Lagoon
>180 days
Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied_
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8
BOW 19060069

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, W, tons, etc.):
Capacity Type Waste Produced r Animal Total
Farrow to Wean
3212 gal/yr
gaVyr
Farrow to Feeder
4015 gallyr
gaVyr
Farrow to Finish
10585 gal/yr
gal/yr
Wean to Feeder
223 galtyr
gaVyr
7200
Feeder to Finish
986 gaVyr
7,099.200 gaVyr
Total 7,099,200 gallyr
AMOUNT OF PLANT AVAILABLE NCTROGEN PRODUCED PER YEAR (lbs):
Capacity Type Nitrogen Produced per Animal Total
Farrow to Wean
5.4 Ibsyr
Ibs/yr
Farrow to Feeder
6.5 Ibs/yr
Ibsyr
Farrow to Finish
26 Ibsyr
lbs/yr
Wean to Feeder
0.48 Ibs/yr
Ibslyr
7200
Feeder to Finish
2.3 Ibs/yr
16,560 Ibs/yr
Total 16,560 I bslyr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 44.73
Total N Required 1st Year: 17904.4
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops: 17,904.40
Total Nitrogen Produced by Farm: 16,560.00
Nitrogen Balance for Crops: (1,344.40)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this BOW 9050079
facility.
2 of 8

Reception Area Specifications
•
11' •1 • • •' • : •
B00101130071 3(a)of8
B00119050071

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements_
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code Crop
A Barley
B Hybrid Bermudagrass - Grazed
C Hybrid Bermudagrass - Hay
D Corn - Grain
E Corn - Silage
F Cotton
G Fescue- Grazed
H Fescue - Hay
I Oats
J Rye
K Small Grain - Grazed
L Small Grain - Hay
M Grain Sorghum
N Wheat
O Soybean
P Pine Trees
Q Matua
Lbs N utilized / unit yield
1.6 Ibs N / bushel
50 lbs N I ton
50 lbs N I ton
1.25 lbs N / bushel
12 lbs N I ton
0.12 lbs N / lbs. lint
50 lbs N / ton
50 lbs N I ton
1.3 lbs; N / bushel
2.4 lbs N / bushel
50 lbs N / acre
50 lbs N / acre
2.5 lbs N I cwt
2.4 lbs N / bushel
4.0 lbs N / bushel
40 lbs N / acre / yr
50 lbs N / ton
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
B00119050072
4 of 8 B0010113007 2

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PAN! rlanimal Farm Total! r
Farrow to Wean 0.134
Farrow to Feeder 1
Farrow to Finish 4A
Wean to Feeder 0.072
7200 Feeder to Finish 0.36 2592
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 2592 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 12960 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayiand at the
rate of 300 pounds of nitrogen per acre, you will need 43 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 103.68 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
It surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
`This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation_ The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. in no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in B00119050073
determining the amount of waste per acre and the proper application prior to applying the waste.
5of8
B0010111 0 I f J

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract
Hydrant
Tye
Crop
inthr
* inches
UN
1
AuB
C
0.6
1
UN
2
AuB
C
0.6
1
UN
3
AuB
C
0.6
1
UN
4
AuB
C
0.6
1
UN
5
BnB
C
0.75
1
UN
6
BnB
C
0.75
1
UN
7
BnB
C
0.75
1
UN
8
BnB
C
0.75
1
B00119050074
6of8
�q y

Additional Comments:
This plan revised to show acres by hydrant rather than by field.
B00119050075
7 of 8

NUTRIENT MANAGEMENT PLAN CERTIFICATION
Name of Farm: BOC #90
Owner: Brown's of Carolina
Manager: Glenn Davis
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. 11we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
I/we understand that i must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. l also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner:
Signature: &DG
Brown's of Carolina
L,01'=
7- e6
Date
Name of Manager (if different from owner): Glenn Davis
Signature:
Date
Name of Technical Specialist: M. Kevin Weston
Affiliation: Brown's of Carolina
Address: 785 Hwy 24 East, PO Box 487
-- — Warsaw, NC 28398 ^
Telephone: [phone]
Signature:.- /z//�
Date
B00119050076
n= y .o b
8of8 ='�`

NrRCS WASTE UTILIZATION
PLAN SPECIFICATIONS
1. Az1.i,mal waste shall -at reach surface waters of the state by runoff, dt :ft. matunade conveyances, direct applicatiou, or
direst discharge durr:. g operation or land application- Any discharge of %vasce which reaches surface water is
prohibited.
2. There must be documentation in the design folder that the producer zither owns or has a notarized agreetmezt for use
of adeg=t: lard on which to properly apply the waste. If the producer does not awn adequate land to properly
dispose of waste, he/she shall provide a copy of a notarized agreement with a landowner who is within a reasonable
proximity, allowing him/her the use of the land for waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when there is a change in the operation, increase in the
number of animals, method of utilization, or available land.
3. AninmaI waste shall be applied to meet, but not exceed, the Nitrogeti ner:li for realistic crop yields based on soul type,
available moisture, historical data, climate conditions, and level of ]nanastment, unless there are regulations that
restrict the rate of application for other nutrients. Actual yield, tiny be uir.I in lieu of realistic yield tables at the
discretion of the planner.
4. Arsit W waste shall be applied on land eroding less than S tons per ac.-re per year. Waste nnay be applied to land that
is eroding at more than S tons but less than 10 tons per acrea per ycar providing erass filter strips are installed where
runoff leaves the field. (See FOTG Standard 393-Filter Strips)
S. Odors can be reduced by injecting the waste cr dishing after waste application. Waste should not be applied when
there is daa:ge: of drift, &m the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will he soil incorporated on conventionally tilled
cropland. When applied to cons -ration tilled crops or grassland, the caste may be broadcast provided the
application flocs not occure during a season prone to flooding. (Sr "«?leather and C liniate in North Carolina" for
guirs:.cr.}
7. Liquid waste shall be applied at rates not to exceed the soil infiitration] rate such that rurod does not occ::re off --site
or to strfacc waters and irn a meL`tad which does ,tot cage drift ft-t,m1 tltc slut, duriui! acation. No poading should
occur in order to control odor and flies.
8. Animal waste shall not be applied to saturated soils. during rainfall events. fir when the surface is fl-ozea-
9. Animal waste should be applied on actively growing crops in such a nlatuier that the crop is not covered with waste
to depth that would prohibit growth. The potential for salt dainage ti'11111 allit:lal Waste shDuld also be considered.
10. Waste nutrie-s s".aIl not be applied in fall or winter for spring plallldd crulls ill .mils with a high potential for
ltachLnz. Waste nt ::--nt loading rates on these soils should he he!d co a 111iniIIJUtn and a suirabie cover crop
pla:._Ted to take up released nutrients. Waste s all not be applied mint -- than 0 da%.s prior to planting of a crop or
"bra
Ycs brciking dormancy.
11. Az: y rrw saute facilirr sited on or after October 1, 1993 shall ccunllty with the fullu%ving: The ou:_r perimeter of
the I=d arcs onto which waste is applied Emrn a lagoon that it, a C0111;.:UnCt Of a sivine farm shall be at leas: 50 fe_t
frorn any residential propemr bounat^_r,V' and from any perer. -;al strewn, or nver utic:- than an irrigation diceh or
c=a`.. At -mal waste ether than waste `-ern facilities satd ua ur after ()crncr 1. 1995, shall not be applied
close-, than 25 tee: to surface water. This distance may be r_duccd tier water; that arc uc�t pa: e:u ial prov ided
ad= =—,e vegetative f lter strips ar= present (Set Standard 395 - Filtc.- -strilis).
B00119050077
B00101130077

IN -RCS WASTE UTILIZATION
PLAN[' SPECIFICATIONS
(COINTRN=)
12. Aw'astz sa a:I not be applied closer than 100 feet from wclls.
13. AaLmal was:z shall not be applied closer than 200 feet of dwellinp; other than those o%�.zzL by imdow-nzr
IA. Wase shall be applied in a manner not to reach other propery and public right-of-ways.
16. Axn mal waste shall not be discharged into suface waters, drainaoeways or wetlands by a discharge or by over-
spraying.nimal waste may be applied to prior converted cropl': td provided it has been approved as a land
applications site by a "technical specialist Animal waste applied on grassed w•at=Avays shall be at agronomic rates
and in a mat;cer that causes no ntnotzor drift from the site.
16. Domestic and industrial waste from washdow-n facilities, showe ;, toilets, sinks, etc_, shall not be discharged into the
ani &I waste managcazent system.
17. A protective cove. of appropriate vegetation AU be established uu all disturbed areas (lagoon embar-kme:its,
b-c-m s, pipe r'=, etc.). Areas shall be fenced, as necessar_-i, to prorccr the vege:atiun. Vegetatiop. such as t= ees,
shrubs, and other woody species, etc_ are ILmited to areas where cntu idered apprupriate. Lagoon areas should be
kept mowed and ac::ssible. La_oon be ors and structures ;licsuld ire iu;l.)cetltd regularly for evidence of erosion,
IeLa2e, or discharge.
18. If meal production at the facilim is terminated, the owner is responsible for obtaining and implementing a "closure
plan' which will elimi_-iate the possibilir: of ar, illegal discharge, pollution and ecusiut:.
19. Waste handling s;rux ores, piping, pumps, reels, etc., should be inspected on a red :lar basis to prtvnt breakdowns,
leaks, and spills. A regular maintenance checcl.sz si,ould be kept ou silt:.
20_ A.-drnal waste can be used in a rotation that i_nc u6es veaeta:bles and >>t11er c: up. for e?ii'_: t h+rrn=n consumption.
However, if animal haste is use: on crops for di: ect hmau it shouts{ only be applied preplan[ wit+`i no
furziner applica6c s of aninnal waste Curing tl:e crop seak!n.
21 _ Ng -ly visible perm-anene, marke-s shall be :rstalled to mark the tub, and bs gam elevations: of the temporary storage
(pu.:.nirig voturne) of all waste treacrrent lagoons. Pumping shall be ainnaged to mainta-in the liquid level betuueen
the mar'K.M. A mark=r will be recuircd to rm-sk the maXiu;tutti st<<r:11-'_ Volun;c ti,r waste s,uranc ponds.
22. Sail tests shall be ,,,ade eve:}- year, and a liquidwaste anulvs:: shall be t: ke:u ,within 60 day: s of application
cors:s;e:.t wi h waste utilization piz_n. Poulu : lire-1 shall be testcd not* to application. Stid and waste anai,'sis
rc=r's shall be kept for five years. -
Dead animals will be disposed c in a mar.,e- that me-'s NC rt _ ul:►titIlls.
B00119050078
I3fl0101130v r 8

U
` North Carolina
Department of Environment and Natural RE
Water Pollution Control System Operator Certi£Zca
Nlichael F. Easley, Governor
William G. Ross Jr., Secretary
Coieen H. Sullins, Chairman
July 26, 2001
Brown's of Carolina, Incorporated
PO Box 487
Warsaw NC 28398
SUBJECT: Designation of Operator in Charge
Farm Name: Farm 90
Facility ID #: 31-678
County: Duplin
Dear Brown's of Carolina, Incorporated:
4J�J 1 4 • f60
ssion
��ACDE R
Senate Bill 1217, enacted by the North Carolina General Assembly on June 21, 1996, requires that a certified operator
be designated as the Operator in Charge (OIC) for each animal waste management system that serves 250 or more
swine, 100 or more confined cattle, 75 or more horses, 1,000 or more sheep, or 30,000 or more confined poultry with a
liquid animal waste management system. Senate Bill 1217 further requires that each certified animal waste
management system operator obtain six hours of approved continuing education training during each three-year period
following initial certification. An operator who fails to complete the required training within 30 days of the end of the
three-year period must take and pass the examination for certification in order to become recertified.
According to Division records, Bradley Herring is the designated Operator in Charge for your animal waste
management system. However, Mr. Herring is no longer a certified animal waste management system operator
because he did not complete the six hours of required continuing education training by December 31, 2000. Therefore,
you must designate a properly certified animal waste management system operator as the Operator in Charge for your
facility.
The enclosed designation form must be returned to this office within 30 days of receipt of this letter. This office
maintains a list of certified operators in your area if you need. assistance in locating a certified operator. Failure to
designate a properly certified Operator in Charge for your facility is a violation of N.C.G.S. 90A--47.2 and
15A NCAC 8F .0201(a) and may result in the initiation of enforcement action.
1618 Mail Service Center,. Raleigh, North Carolina 27699-1618
Phone: 919 — 733-0026 1 FAX: 919 — 733-1338
AN EQUAL OPPORTUNITY 1 AFF[RNIATIVE ACTION EMPLOYER - 50% RECYCLED 1 10% POST CONSUMER PAPER

Brown's of Carolina, Inc.
Page Two
July 25, 2001
If you have questions concerning this matter, or if this office can be of further assistance, please call Beth Buffington at
[phone], extension 313.
Sincerely,
Tony Arnold, Acting Supervisor
Technical Assistance and Certification Unit
Enclosure
cc: TAC Files
Non -Discharge Compliance/Enforcement Unit
Wilmington Regional Office
Central Files
Bradley Herring
[1

oF wAr�,�QG
February 7, 2001
Mr. Gus Simmons
Brown's of Carolina
PO Boa 487
Warsaw, NC 28398
Michael F. Easley
Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Subject: Inspection Forms
Farm # 20 and Farm 90
31400 and 31-678
Duplin County
Dear Mr. Simmons:
Kerr T. Stevens, Director
Division of Water Quality
Please find enclosed copies of the lagoon prioritization inspection sheet for the referenced
facilities for the inspections that were performed on January 18, 2001. I was able to leave copies of these
forms which had only partially been completed at the time of the inspections. The enclosed are copies of
the completed forms.
3900.
If you have any questions regarding this matter, please do not hesitate to contact me at 910-395-
Sincerely,
Stonewall Mathis
Environmental Engineer
enclosures
cc: Wilmington Files 31-400
Wilmington Regional Office
Phone. 9I0-395-3900
127 Cardinal Drive Extension Fax: [phone]
Wilmington, NC 28405-3845

FEB-1.5-00 TUE 11:46 AM BROWN S
FAX NO. 9102961675
P. 1

FEB-22-00 TUE 6:11 PM BROWN S FAX K0, 9102961675 F. l
..-'�.'-e,y+-v.n .:�.:a-�<<..m_,_... .. ��.�;.�xi=�.._�. 5.1-vaar�_�"!r c-siw,n Y--,�...•-r�ee�...ar�x,reeroac n�']�5�7`rari"r='�3."_�.:.e.�.'T:'_:,�i • �. rsiti� r�:ISF.. ° -.z� vr��n
Feburary 21, 2000
To : Greer McVicker
From: Brown's of Carolina, Inc.
Subject: Lagoon Levels Update
The following lagoon were less than 19" as of Feburary 19, 2000.
'�t'-1 Farm # 1
1s"
31-3c. Y Farm # 3
1a.
^!
rl`('(
Farm # 17S
'14~'
t—L 00 Farm* 20
12"
11 t�
lV J Farm # 34
1 7:
Farm # 35
11 6"
.
-3 iFarm #90
1s,
Please call if you wish to discuss these lagoons or the actions underway to alleviate
these hivh levels.
Jimmy Vinson 910-290-1800 (Office) 910-290-4459 (Mobile)
Glenn Davis 910-296-1800 (Office) 910-290-0366 (Mobile)
BROWN'S OF CAROLINA, INC.
785 HM 24 EAST • P.O. BOX 487 • WARSAW. N.C. 28398 • PHONE (910) 296•1900

APR-10-00 MON 9:39 AM BROWN S FAX NO. 9102961675 P, 3
BROWN'S Running Lagoon Level & Rainfall Report
OF CAROLINA Farm Name: 90
Date Lagoon Level Riin[J-11(1=89
3 1 10/9/99
�B
23
0.9
10/23/99
15
0.8
10/30/99
17
0
1 1 /6/99
18
1.4
1 1 / 13/99
22
0
11 aaou
]6
0
11/27/99
23
1.25
12/4-/99
24
O
12/ 1 1 /99
24
0.2
12/ 18199
23
1
12/25/99
24
0.4
f
�'
Monday. April 10. 2O00 Page 3

APR- 0-0-0. MON 9:39 AM
BROWN 5
FAX NO. 9102951675 P. 7
BRa1NN'S
Running
Lagoon
Level & Rainfall Report
OF CAROLINA
1-:arM Name.
90
Date Lagoon Level
Ralniall(inches
111 /00
24
0.3
1 /S/00
24
0.3
1/15100
24
1.8
1/22/00
23
0.5
1 /29100
20
1.5
2/5/00
19
0.8
2112100
17
0
2/ 19/00
Is
0.8
2/26100
20
0
3/4/00
22
0.1
311 1 /00
26
O
311 B/OO
28
2
N25i00
26
0.9
4/1/00
26
0.8
Monday. AXut1 10. 2000 Page 3

SIP-06-00 WED 04:41 PH BROWN'S OF CAROLINA!
■
BROWNIS
�- OF CAROLINA
F;w,
From:
FAX NO. 2961333
Yl-t78
7a5 Hwy 24 East
PO Box 487
Warsaw, NC 2839B-0 97
91 C -298`l ow
1-800-571-C3328
910-296-81158 — Pax
Cl UrAan2 El FOV ReAaw 0 Pleas Comment ❑ Alcaase Reply ❑ Pla"a Racycla
AL L.'Q9T3K6S�y'dC:�:
September 6, 2000
SLibjel: t : Lagoon Levels Update
The, fe-Howing lagoon is within the 19" of freeboard as of September 5, 2000.
Farm # 35 12" Plan of Action 8/29/00
Farm # 90 18"
Our pl-an of .act:ar) is to apply land applications as soon as the rains subside and the
f;elds rare nc longer saturated. Please call if you wish to discuss these lagoons or the
erctions underway to alleviate this high level.
Gus &111010)s 910-296-1800 (Office)
G'Ar:n D�ivis 910-296-1800 (Office) 910-290-0366 (Mobile)
I
P. 01

:!EP-05-00 WED 04:41 PM BROWN'S OF CAROLINA! FAX N0, 2061333
P, 02
PLAN OF ACTION (PoA) FOR HIGH FREEBOARD AT ANIMAL FACILITIES
;-acility Nun,::. r. 3i - r ' County:
FELLility
Certified Opc-rater Name:
Dct pc.,,j
Operator
1. CuFrent liquid leval(s) in inches as measured from the current liquid level in the lagoon to the
lowest point c?i the too of the dam for lagoons without spillways; and from the current liquid level
In the Ingoon to the bottom of the spillway for lagoons with spillways,
Structure 1 Structure 2 Structure 3 Structure 4 Structure 5 Structure 6
t aaoon Nirne/ldentif -or (ley
pill�vy (Yes o; No): Al
I-eVe1 (:_.C1,"es): /?,
2. Check atl applirab!e items
Liqu d lev-�i is within the designed structural freeboard elevations of one or more structures.
Five and 30 day Plans of Action are attached_ Hydraulic and agronomic balances are within
acceptabl9 ranges,
r/ L:qu'd lev,�l is within the 25 year 24 hour storm elevations for one or more structures. A 34 day
Plan of Action is attached. Agronomic balance is within acceptable range.
Wzste is ;o be pumped and hauled to off site locations. Volume and PAN content of waste to
pumped ��nd hauled is reflected in section III tables. Included within this plan is a list of the
p, oposed sites with related facility number(s), number acres and receiving crop information.
Cor:tact a.nd secure approval from the Division of Water Quality prior to transfer of waste
to a site riot covered in the facility's certified animal waste management plan.
O e-ation will be partially or fully depopulated.
- att:�dl a complete schedule with corresponding animal units and dates for depopulation
- if Cininnals are to be moved to another permitted facility, provide facility number, lagoon
hea4 )card levels and herd population for the receiving facility >
Earliest possible date to begin land application of waste:
I hereby ce_ Iny tl'iat I have reviewed the information listed above and included within the attached Plan
of Action, and to the test of my knowledge and ability, the information is accurate and correct.
Phone:
--- — - Fa4' lity Owner/Manager (print)
{.. �,r G., ..�� f% /� %<—�� •' Date: 9 G azs
s
Far; lity Owner/Manager (signature)
pr,A Covet rage 2/2V00

SEP-!�6-00 WED 04: 42 PH BROWN'S OF CAROLINA! FAX NO, 2961333 P. 03
l
PLAN OF ACTION (PoA) FOR HIGH FREEBOARD AT ANIMAL. FACILITIES
30 DAY DRAW DOWN PERIOD
1. TO VA1 PAN TD E)E L4ND APPLIED PER WASTE STRUCTURE
1. SS> idure Naine/Identifier (ID): a—o c #90
2. Current liquid volume in 25 yr./24 hr. storm storage & .structural freeboard
a. current liquid level according to marker 1 8,0
j inches
b. designed 25 yr./24 hr. storm & structural freeboard 19.0 inches
c, line h line a (inches in red zone) = 1.0 inches
d. top of dike surface area according to design
(area at below structural freeboard elevation) 151988 ft2
e_ line c/12 x line d x 7.48 gallons/ff3 94738 gallons
3. PrCilecied voiurne of waste liquid produced during draw down period
f. temporary storage period according to structural design 180 days
g. volume of waste produced according to structural design 237369 63
h. current herd # 7200certified herd # 72l)0
actual waste produced = current herd # x line g =
certified herd #
i. volume of wash water according to structu dal design
j. excess rainfall over evaporation according to design
k. (lines h + i + j) x 7.48 x 30 days/line f=
4. Tol it PAN to be land applied during draw down period
1. current waste analysis dated 1 7/21/00
rn. ((fines e + k)11000) x line I =
REPEAT SEt: i ICrN I FOR EACH WASTE STRUCTURE ON SITE.
(Click on the .text Structure tab shown below)
237369 n3
L_ _ �1ft3
91875 ft3
410458 gallons
2.70 ibs/1000 gal.
1364.0 lbs. PAN
PoA (50 Day) -J�. o(j

'REP-06-00 WED 04:42 Phi BROWN'S OF CAROLI A! FAX NO. 2961333 P. 04
11. TOTAL POUNDS OF PAN STORED WITHIN STRUCTURAL FREEBOARD AND/OR 26 YR./24
RR, STORM S-rORAGE ELEVATIONS IN ALL WASTE STRUCTURES FOR FACILITY
1. Srrodure 1D: DOC #90 line rn = 1364.0 lb PAN
2. S,ruchire ID.- fine m � lb PAN
3. S`.-n cture !D_
5. Structure 1D:
G. SI.r.,,cl ire ID:
line m r
lb PAN
line m =
lb PAN
line m =
lb PAN
line m =
lb PAN
n.lines 1+2+3+4+5+6= 1364.0lbPAN
Ill. TOTAL FIAN PA'-ANCE REMAINING FOR AVAILABLE CROPS DURING 30 DAY DRAW DOWN
PERIOD, CO i lOT LIST FIELDS TO WHICH PAN CANNOT BE APPLIED DURING THIS 30 DAY PERIOD.
o, fmrA;�
`
p, fi£�1d i0
Q crop
r. acres
s. remainirkg ERR-
2 PAN balance
(Ibias,Fe)
L TOTAL PAN
BALANCE FOR
FIELD (Ibs.)
column r x s
u. spplicaiion wrtdow'
T524
Fl1
Scrrnuda
7.56
250.00
1890.0
Mar -Sept
7624
H2
Bermuda
4.47
230.00
1028.1
Mar -Se t
- ..4
H3•Bermuda
5.51
210.00
1157.1
Mar -Sept
'State cirreni crop eldined application date or next crop application beginning date for available
receiv ng crcps during 30 day draw down period.
v. Total PAN available for all fields (sum of column t) = 4075.2 lb. PAN
IV. FA�-_l'Li VS PoA OVERALL PAN BALANCE
w. ': etal PAN to be land applied (line n from section 11) = 1364.a Ib. PAN
PoA (30 Gay) 2J210)

SEP--06-09 WED 04:42 PM BROWN'S OF CAROLINA! FAX NO. 2961333 P. 05
r. Crop's remaining PAN balance (line v from section tli) = 40752 lb. PAN
y. Overall PAIN balance (w - x) = -2711 lb. PAN
Trine y must sh*wi as a deficit. If tine y does not show as a deficit, list course of action here Including pump and
haul, r# popijia:iofi, herd reduction, etc. For pump & Haul and herd reduction options, recalculate new PAN
based on n'-w infrrmation. If new fields are to be included as an option for lowering lagoon level, add these
fields to tka PAN baVince table and recalculate the overall PAN balance. If animal waste is to be haulr d to
ariott er PanTlit" ed facJlity, provide information regarding the herd population and lagoon freeboard levels at the
Pee (33 Day) 2?2tltlC

SEP-20'00 WED 04:13 PM
BROWN'S OF CAROLINA!
FAX NO, 2961333 P. 01
qff,pf-n) -7/ -6�8
SEP 21 2000 k 7O No 24Fcaix
SEast
� O
1�ROYYNe
F CARQLINA
f
PO 8or 487
Warsaw, NC 2839Q-0497
91 a�s-1 soo
910.2s�s16s -
Fax
Fast: ��1�; ��� Pages: 1 _.
Date: - Q-A --
Rxs: CG;
0 Uirgent 0 For Review ❑ Please Comment ❑ Ploa<se Reply © Please Rs:cycle
September 20, 2000
Subject : Lagoon Levels Update
The fo'lawing lagoon is no longer within the 19" of freeboard as of September 19, 2000.
Farm # 90 23R
GLIS S mtnons 91D-296-1800 (Office)
Clettin Davis 910-296-1800 (Office) 910-290-0366 (Mobile)
Kevin Weston 910-2C06-1800 (Office)

;a .` - �-� - .._s lt�.M ........::.-v-='qe • _ .yea..=.�. r:- .cam..-_,-..,�,.�,�.a _ti--�-�-_may_ ..�.�.
Th - 3�kb -- 2DbY
Send to itiilnl noon office
EHIt6rgebcy Plan of I ctiaa
To: Rick Shiver, DWQ —Wilmington Regional Office
From: Gus Simmons
CC: Jimmy Vinson
Date: February 16, 2000
RE: gown`s of Carolina Farms #34, #90 31-1'18
Summary:
The following Action PIan outlines the steps, procedures. and management direction for lowering
the liquid level and maintaining the structural integrity of the waste treatment and storage inymundinents at
the aforementioned farms_ This plan discusses the required actions and available means of maintaining the
structural integrity of the impoundments, and fiutiwr ruing the additional 7 inches of operational
freeboard as specified m ttL General Permit for these facilities through inumsif-ed facility management.
1. Accurate Liquid Level Measurements_ A simple, but axcssary, step is to ensure that liquid levels are
being accurately measured to preverit overestimating or underestimating the current liquid level for
each lagoon. This process includes verifying the elevations of the gruff gauges with the actual top of
dike elevations for each impoundment with a reported liquid level freeboard of less titan 19 inches,
Soil Moisture Condition Analysis. The iicest and most efficient say of towering the liquid levels is
ID llbir Mp5pay il17Ti411 i jPrs.inT4 for these facilities for wastewater e$luent agplicxtion i aa:
main constraint on operating tires:, systems to !heir design mpabtliry the past 2-3 weeks has bwr; a
problem of hydrology. The recant snow and nightly freezing conditions has left most application
fields, as specified in the waste management plan for each facility, at soil moisture levels above fieie
condition. To prevent run-off and still perform effluent applications at every available opportunity, me
environmental management staff, including our staff' Crop Specialist and TevWcal Specialist are
assisting our field personnel with moisture conditioa This also includes makuig frequent, micrc-
appiications(C0.25` applications) with our existing irrigation equipment to reduce surface infiltration
impacts associated with heavier applications.
3. lntensifled Fresh Water Conservation. The Production Staff at Brown's of Carolina had adopted and
Emergency Fresh water Conservation Plan whirl[ outlines steps Lobe tarkeri to reduce fresh seaterusage
on our facilities. Ttiic includes reduced sanitation practices. Although this compromises The
bimecurity of the facilities, it is a method of radu ing liquid input into the impoundments. In addition,
as further means of policing influent amounts, fresh, water usage is measured daily on all facilities
operating with less than 19 ,inches of freeboard.
Page 3 of 4

4. Evaluation of Alternative EMuem Storage. An immedi= short-term aid for some funs may be to
obtain additional efliumd storage within the facility, itself_ An example would be to mAc sure that the
overflows for each pull -plug fcility are set to the correct elevation. A l'ew inches of storage may be
obtained in some pits in this manner. Also, the possibility e3dsts in temporarily convMmg some flush
barns to pit — recharge to gain additional storage capacity.
5. implementation of AlWmativa waste Application Sites. As many of the particularly well drainW, or
"drier" soil -type hydmuts are ap roadring the application goal of plant Available nitrogen (PAN) due
to the post -Floyd irrigation events, it may be necessary. on some sites, to obtain additional application
land via a Nutrient Management Plan (NUP) addendum_ Application of effluent to these receiving
sls may r«Nu� ms > 9 IMM MASI MUWK raw -his W WNW
personnel, It uwy also require the unplernenlation of "pump and haul"_ in either case, effluent will be
APPUad-M thUd 00iiNtiall fietdt d AMIMmia lH and M sgOMW in the addendum of the NW for
these sites, created by a certified Technical Specialist.
As always, Brown's of Carolina is committed to the compliant operation of all its facilities. Brown's of
Carolina recognizes the intensified effort required to manage these higher liquid levels. It is our policy not
to place animals in any of our farms in which the impending environmental risk may lead to a discharge or
ftutwMrMly GdUV by Mn RkH= of N=§ !n Ow fifilul.
Brown's of Carolina appreciates the cooperative efforts of the Division of Water Quality and its staff in
these efforts and this Emergency Plan of Action.
Page 4 of 4

Facility Number Lagoon Number ......I .... ... Lagoon Identifier ..... ....................._..,........ ...,...................
MActive O Inactive Latitude 3� S(, [I [ I Longitude rj8F671 3 3
3y GPS or Map? VGPS ❑ Map I GPS file number: I 3j a io?$
35. Surface Area (acres):
36. Embankment Height (feet):
37. Distance to Stream:
38. Water supply well within 250 ft of the lagoon?
❑ On -site ❑ Off -site
39. Distance to WS or HQW (miles):
40. Overtopping from Outside Waters?
41. Constructed before 1993 NRCS Standards?
42. No verification of adherence to 1993 or subsequent
NRCS Standards?
,+. o B
bless than 300 ft Q 300 ft - 1000 ft O greater than 1000 ft
O Yes J6 No
0<5 05-10 Uj>10
O Yes 0 No O Unknown
OYes ONo OUnknown
Oyes ffl No O Unknown
43. Was groundwater encountered during construction? O Yes O No X Unknown
44. Depth to Groundwater: 9 Unknown
45. Spillway? O Yes .9 No
AdCr
46. �e Marker? *Yes JgNo �' • S
47. Immediate threat to the integrity of the structure?
48. Freeboard & Storm Storage Requirement (inches):
qq. Are rack otA4r-Caps p,-ese,47
O Yes X No
2- "
r4
A101

i
State of North Carolina
Department of Environment
and Natural Resources
1IX,
Wilmington Regional Office 4 R
James B. Hunt, Jr., Governor NCDENR
Bill Holman, Secretary
Kerr T. Stevens Director NORTH CAROLINA EDFPARTMENT OF
! ENvIRONMENT AND NATURAL RESOURCES
Division of Water Quality
April 13, 2000
CERTIFIED MAIL # P 328 829 360
RETURN RECEIPT REQUESTED
Mr. Jimmy Vinson
Brown's of Carolina, Inc.
BOC Farm # 90
PO Box 487
Warsaw, NC 28398
Subject: Notice of Deficiency
BOC Farm # 90
Facility Number: 31-678
Duplin County
Dear Mr. Vinson:
This is to notify Brown's of Carolina, Inc., who holds a non -discharge permit for an animal waste
disposal system pursuant to 15A NCAC 2H .0200 and North Carolina G.S. 143.215.1, of a deficiency of
Animal Waste Permit AWS 310678.
On February 19, 2000, it was reported by your facility that the freeboard level in your lagoon was
not in compliance with a level of 18 inches. Therefore, this notice is being sent in accordance with the
Division of Water Quality's (DWQ) high freeboard policy.
You should have submitted a Man of Action to obtain compliance within a stipulated time frame
depending on your lagoon level. The following procedure is to be implemented whenever the freeboard
level in any lagoon is not in compliance:
1. Notify DWQ Wilmington Regional Office within 24 hours
2. Submit appropriate Plan of Action documents obtained from DWQ, Soil & Water district
office, or Service Company
3. Provide DWQ Regional Office with weekly updates
4. Notify DWQ Regional Office when compliance is attained.
It is highly recommended that this facility: 1) explores and initiates measures to conserve fresh
water usage and 2) make any necessary changes to the waste management system and/or waste
utilization plan to help maintain appropriate lagoon levels.
127 North Cardinal Dr., Wilmington, North Carolina 28405 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Emplover 50%, recvcied/10'% Post -consumer paper

0
111
ft.
I�P P 328 829 360
Receipt for
Certified Mail
No Insurance Coverage Provided
. - --— --- -........1 AA-;l
Mr. Jimmy Vinson
PO Box 487
Warsaw, NC 28398
Postage $ , 3
Certified Fri- Ob
1 I Soecial Delivery Fee
Restricted Delivery Fei-
m Rewrn Rrceipr Showing t�
IT to Whom & Date Delivered / 2 7
0 Return Ruceipl Showurg to 1
Date, and Addrvssue' ess
rOTAL Nislage
C& Fees
Postmaik or We
ce) t �� f
E
o ,
N
a. `� /

I
Mr. Jimmy Vinson
April 13, 2000
Page 2
The Division of Water Quality will take no further action for this reported incident at this time.
DWQ may pursue additional actions including civil penalties, injunctive relief, or revocation of your
Animal Waste Permit AWS 310678 for future occurrences..
If you have any questions concerning this matter please do not hesitate to contact either Mr.
Stonewall Mathis or myself at [phone].
Sincerely,
Dean Hunkele
Environmental Specialist
cc: Harold Jones, Duplin County Soil and Water Conservation
DWQ Non -Discharge Operations Branch File
DWQ Wilmington Animal Files 31-678
S:IWQSIANIMALSIDUPi_IN12000131-678 BOC 90 NOD.wpd

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
Brown's of Carolina, Inc.
Farm 90
PO Box 487
Warsaw NC 28398
Dear Brown's of Carolina. Inc.:
1?W'J
A/ NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
December 30, 1999
Subject: Fertilizer Application Recordkeeping
Animal Waste Management System
Facility Number 31-678
Duplin County
This letter is being sent to clarify the recordkeeping requirement for Plant Available Nitrogen (PAN)
application on fields that are part of your Certified Animal Waste Management Plan.
In order to show that the agronomic loading rates for the crops being grown are not being exceeded, you
must keep records of all sources of nitrogen that are being added to these sites. This would include nitrogen
from all types of animal waste as well as municipal and industrial sludges/residuals, and commercial fertilizers.
Beginning January 1, 2000, all nitrogen sources applied to land receiving animal waste are required to
be kept on the appropriate recordkeeping fortes (i.e. IRRI, IRR2, DRY1, DRY2, DRYS, SLURI, SLUR2,
SLD1, and SLD2) and maintained in the facility records for review. The Division of Water Quality (DWQ)
compliance inspectors and Division of Soil and Water operation reviewers will review all recordkeeping during
routine inspections. Facilities not documenting all sources of nitrogen application will be subject to an
appropriate enforcement action.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement_
If you have any questions regarding this letter, please do not hesitate to contact Ms. Sonya Avant of the
DWQ staff at [phone] ext. 571.
Sincerely,
r
Kerr T. Stevens, Dir for
Division of Water Quality
cc: Wilmington Regional Office
Duplin County Soil and Water Conservation District
Facility File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

Revised April 20, 1999
JUSTIFICATION & DOCUMENTATION FOR MANDATORY WA DETERMINATION
Facility Number 3 k -b2'�_
Farm Name: #90
On -Site Representative: Gus ?s
InspectorlReviewer's Name: L' IV.1. L,
Date of site visit: $15 _
Date of most recent WUP: is 6jr AB
Annual farm PAN deficit: pounds
Operation is flagged for a wettable
acre determination due to failure of
Part U eligibility item(s) F9 F2 F3 F4
Operation not required .to secure WA
determination at this time based on
exemption Et E2 E4
Operation pended for wettable acre
determination based on P1 P2 P3
Irrigation System(s) - circle #: 1. hard -hose traveler; 2. center -pivot system; 3. linear -move system;
4. stationary sprinkler system wlpermanent pipe; 5. stationary sprinkler system w/portable pipe;
B. stationary gun system w/permanent pipe; 7. stationary gun system wlportable pipe
PART I. WA Determination Exemptions (Eligibility failure, Part II, overrides Part I exemption.)
E1 Adequate irrigation design, including map depicting wettable acres, is complete
and sinned by an I or PE.
E2 Adequate D, and D)D3 irrigation operating parameter sheets, including map
/ depicting wettable acres, is complete and signed by an I or PE.
� E3 Adequate D, irrigation operating parameter sheet, including map depicting
wettable acres, is complete and signed by a WUP.
E4 75% rule exemption as verified in Part III. (NOTE:75 % exemption cannot be
applied to farms that fail the eligibility checklist in Part IL Complete eligibility
checklist, Part 11 - F1 F2 F3, before completing computational table in Part III).
PART I1.75% Rule .Eligibility Checklist and Documentation of WA Determination
Requirements. WA Determination required .because operation fails one of the eligibility
requirements listed below:
_ F1 Lack of acreage: -which Tesultedsnmver:applicationmfwastewater_(PAN) on:spray_
field(s) accordina-tofarm'sdasttwoyearsmf:imaation-xeconJs.-.
F2 Unclear, illegible; or lack of information/map.
F3 Obviousfeld-limitations-(numerousAdches;failure#o:deductzequired .. _
bufferlsetbackmcreage; nr25%:ofiotal_acreageadentfedan`CAWMP indludes =
small ,-irregularly-shaped.fields fields -less -than -5mcres for. travelers-or.less-than
2 acres for stationary -sprinklers).
F4
WA determination required because CAWMP credits field(s)'s acreage -in excess
of 75% of the respective field's total acreage as noted in tabL,:! in P,-rtIll

Revised April 20, 1999
Facility Number
Part lll. Field by Field Determination of 75% Exemption Rule for WA Determination
TRACT
FIELD
TYPE OF
TOTAL
CAWMP
FIELD
COMMENTS'
NUMBER
NUMBER''2
IRRIGATION
ACRES
I
ACRES
SYSTEM
FIELD NUMBER' - hydrant., pull, zone, or.point numbers may be used in place of field numbers depending on CAWMP
and type of irrigation system. If pulls, etc. cross more -than one field, inspector/reviewer will have to combine fields to
calculate 75% field by field determination for exemption; otherwise operation will be subject to WA determination.
FIELD NUMBER2 - must be clearly delineated on map.
COMMENTS'- back-up fields with CAWMP acreage-exceeding'75% of its total acres and havino received less than 50%
of its annual PAN as documented in the farm's previous -two years' (1997 & 1998) of irrioationrecords,-cannot serve as the
sole basisforrequiring G WA Detenmination.LBack-up fiields-must-be -noted in the,commeritzectionand must be accessible
by irrigation system.
Part IV. Pending WA Determinations
Pi Plan lacks .followinciinformation:
P2 Plan revision may:s2tisfy75% rule based on adequate overall PAN deficitt-and by
adjusting all field-acreage:io below 75% use rate
P3 Other (ie/in process of installing new irrigation system):

-... - V
W10
State of North Carolina
7BY--7-
p'artment of Environment, Health and Natural Resources �j + ?�
Division of Water Quality
JulNon-Discharge Permit Application Form / Survey
(THIS FORM MAY BE PHOTOCOPIED FOR USE AS AN ORIGINAL)
General Permit - Liquid Animal Waste Operations
The following questions have been completed utilizing information on file with the
Division. Please review the information for completeness and make any corrections-,
which are appropriate. If a question has not been completed by the Division, pltse '*
complete as best as possible. Do not leave any question unanswered.
Application Date: 7-i-_ l
ti !
::0 tom''+
1. REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to ea h q=Q
item. C X
Awlicants Initials
1. One completed and signed original and one copy of the application for General Permit - Animal 40
Waste Operations;
2. Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is disposed;
3. Two copies of the Certified Animal Waste Management Plan (CAWMP). If the facility does
not have a CAWMP, one must be completed prior to submittal of a general permit application
for animal waste operations.
II. GENERAL INFORMATION:
1. Farm's name:
2. Print Land Owner's name: Brown's of Carolina,
3_ Land Owner's Mailing address: PO Box 487
City: Warsaw NC zip: 2$33I 09310
Telephone Number:944!293-360(1 qto 7M. /fov
4. County where farm is located: Du lin
5. Farm Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a copy
go
of a county road map with the location of the farm identified): � 1105- &n. `ilRiGfj*d %t 2 f�,dre�,s.
Print Farm Manager's name (if different from Land Owner):
7. Lessee's / Integrator's name (if applicable; please circle which type is listed):
3I - 678
FORM: AWO-G-E 2/26/97 Page I of 3

III. OPERATION INFORMATION:
1. Farm No.: 31-678
2. Operation Description: Swine_operation
Feeder to Finish
7200 - Certified Design Capacity
Is the above information correct? ayes; 0 no. If no, correct below using the design capacity of the facility
Type of Swine No. of Animals Tvne of Poultry No. of Animals ' yj& of Cattle No. of Animals
0 Wean to Feeder
0 Feeder to Finish
0 Farrow to Wean (# sow)
0 Farrow to Feeder (# sow)
0 Farrow to Finish (# sow)
Other Type of Livestock on the farm:
0 Layer 0 Dairy
0 Non -Layer 0 Beef
0 Turkey
of Animals;
3. Acreage cleared and available for application:; Required Acreage (as listed in the CAWMP): 55
4. Number of Lagoons: 4L— ;Total Capacity: %0 957 Cubic Feet (ft)
Number of Storage Ponds: ; Total Capacity: Cubic Feet (0)
5. Is animal waste being applied on any field which has subsurface drains? YES or O (please circle one)
6. Are subsurface drains present in the vicinity of or under the lagoon? YES or O (please circle one)
CATION:
I, �J1 /'1'] 1'1'f V I%- V fIVJ on+ I rwx rv- FM NY "Al (Land Owner's name listed in question 11.2), attest that
this application for I IX4t 6,F- a6441V 1. A/C . F�y► 10 (Farm name listed in question II.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be urn o me as incomplete
Signature Date 7-1- 97
V . MeGEWTSIERTIFICATION: (complete only if different from the band Owner)
I, (Manager's name listed in question 1I.6), attest that this
application for (Farm name listed in question II.1)
has been reviewed by me and is accu to and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and t if all required supporting information and attachments are not included, this application package
will eturn d as incomplete.
C
Signature Date
THE (OWLE`IIW APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
V SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
PERMITS AND ENGINEERING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FORM: AWO-G-E 2/26197
Page 2 of 3

State of North Carolina
Department of Environment, Health and Natural Resources
Division of Water Quality
Non -Discharge Permit Application Form / Survey
(THIS FORM MAY BE PHOTOCOPIED FOR USE AS AN ORIGINAL)
General Permit - Liquid Animal Waste Operations
DIVISION OF WATER QUALITY REGIONAL OFFICES (2/97)
Asheville Regional WQ Supervisor
59 Woodfin Place
Asheville, NC 28801
[phone]
Fax [phone]
Avery
Macon
Buncombe
Madison
Burke
McDowell
Caldwell
Mitchell
Cberokee
Polk
Clay
Rutherford
Graham
Swain
Haywood
Transylvania
Henderson
Yancey
Jackson
Fayetteville Regional WQ Supervisor
Wacbovia Building, Suite 714
Fayetteville, NC 28301
[phone]
Fax [phone]
Washington Regional WQ Supervisor
943 Washington Square Mall
Washington, NC 27889
[phone]
Fax [phone]
Beaufort Jones
Bertie
Lenoir
Camden
Martin
Chowan
Pamlico
Craven
Pasquotank
Currituck
Perquimans
Dare
Pitt
Gates
Tyrell
Greene
Washington
Hertford
Wayne
Hyde
Mooresville Regional WQ Supervisor
919 North Main Street
Mooresville, NC 28115
[phone]
Fax [phone]
Anson
Moore
Alexander
Lincoln
Bladen
Richmond
Cabarrus
Mecklenburg
Cumberland
Robeson
Catawba
Rowan
Harnett
Sampson
Cleveland
' Stanly
Hoke
Scotland
Gaston
Union
Montgomery
Iredell
Winston-Salem Regional WQ Supervisor
585 Waughtown Street
Winston-Salem, NC 27107
[phone]
Fax [phone]
Alarnance
Rockingham
Alleghany
Randolph
Ashe
Stokes
Caswell
Surry
Davidson
Watauga
Davie
Wilkes
Forsyth
Yadkin
Guilford
Raleigh Regional WQ Supervisor
3800 Barrett Dr.
Raleigh, NC 27609
[phone]
Fax [phone]
Chatham
Nash
Durham
Northampton
Edgecombe
Orange
Franklin
Person
Granville
Vance
Halifax
Wake
Johnston
Warren
Lee
Wilson
Wilmington Regional WQ Supervisor
127 Cardinal Drive Extension
Wilmington, NC 28405-3845
[phone]
Fax [phone]
Brunswick New Hanover
Carteret Onslow
Columbus Pender
Duplin
FORM: AWO-G-E 2/97 Page 3 of 3

flF<CAROLiN'
BROWN'S OF CAROLINA - FARM
9 (800) FEEDER TO FINISH
STATE ROAD #1105 - DUPLIN COUNTY
DIRECTIONS: FROM WARSAW, TAKE HIGHWAY #20 TOWARD CLINTON.
TURN LEFT ONTO STATE ROUTE #1105. AFTER APPROXIMATELY 4 MILES TURN
RIGHT AT CARLTON CHAPEL. FARM WILL BE APPROXIMATELY 0.25 MILES ON
RIGHT.
MAILING ADDRESS:
BROWN'S OF CAROLINA
P.Q. BOX 487
WARSAW, NC 28398
WORK: [phone]
SHIPPING ADDRESS:
BOC #20 FINISHING
STATE ROUTE #1105
WARSAW, NC 28398
BROWN'S OF CAROLINA, INC
303 EAST COLLEGE STREET • PO BOX 487 • WARSAW, N.0 28398-0487 • OFFICE. [phone] • FAX: [phone]

AN—ME-1 7cxs IMF iT Z'Z C T_ c' �Ci=;CS7 $OR ITMW OR =PA ==
?!"so =at=, t!t& cc„? atad fo= to tha D'_T'_s_z_ of ��_ ..—�: =a+ '.i�s��•- _ :t
��v :c'�_�aaY cat �Q t•ava;sue sid's of t':'_p fc=. r
Ne_:_e of fa-=, ilYase Wit) L�(cJ,i/S _ C� [P/t��L//l/r'�
�
Phone No.
pa--= ?ocat'_cc. Latitude ar_d Long it, -de: ` ��`%fig"� "(=e�si-ec} .n A -ISO,
Please a Copy C.-Pr a cotL_ty road B:zp wic-h Ioc2.tiolr iCeµt=f: ed.
'I _re of cPezatioa (s��^e, layer c2a=_y, etc.} -- ��' 7 - -- - -
Des:.ga caozc_t'y (nt....ioe= cfa.:--zls) •� ACC' � •—
Ave,age s_ze c aLe,aticr_� (Y7 ccor:th'popu7atior. avg.)
Average ac,ea-e n ee;-e- far 1 .d application_ of ;J�--et (acres) 5 5
__�._ _ __ a Y a=31s3 =32a22y3•r3Y�33i3iiiiiii32it Yi=32333322y =_3333Ya2Y3 i3i2322 i.S ,Z.�3Y si
��C_.��C31 51}�C+�•���4 44��wr�ti�r'.�orr
As a ca,' SpeC4 a; -;St des_s:-sated by the Nort Ca:olicz Sail aLd hater
Ccase--aticn Cori ss;or_ pu=s—ua.` t to i5A NC2.0 67 .0005, I ce=ti`y that the new or
expa._ded waste =amage-nar_t system as i-nstzlle-d for the fa_= named' above
i:zs a:. ari a1 waste tz^.agecerzt p?ati that Ceets the desigri, Con sz-ructica,
Geezer_,.. ar... :.B4=.4L.a_aCe 7Garsn-Sta�ZTso^niwCi.
X-az ague_^_t a---d the USDA-Scil Conservation Service and/or the North
Czro? hz Sc*? and Water Corse= rat—n to ?;?. NCnC 2H.0217 a=.d
i�:A NC=.0 6= .0001 -_ 0005 - The following e`-aments ar_d t eiz car_ espondin g rrI,
Crlt?=�? Cam' ����I�Vdi'_�red by rile or ctier C=5?yi.2-=d soecia fists an
Ze _CI��...e^ �-: t_:e ply^. as a;�?I;CabIe: Lim.^.; -:'T._.i' Sa=ara`ions (huars) . 1=:1==s or
ei»valerlt for lagcois Cr wasce sz�'oraCJe pond's; Waste stiGra a Capac"_GV; zCeq�.: to
C',Za;.-4C-/ are a._Cunt of la._z =Gr WaSte Urij.'.Z=r;a- (or 1, Of th4=d pa='.�yaccess
a= o.-e_s sip ct prope, waste a=gI iCat_on a ;- ipr.e^_ sc hedtile far ting of
ra.;-as; 1oae-L g rats, and: the Control of the aischazge
Off polltta_:ts fzam sta_--.:ate_ =1.Zoff events less save,e than the 25-yea;, 24-hatL
sta=.
ISa=.A cr Tac__c
1 C: 0
Add`ass
SpaC: ZL it 12 leas a --IIA" </ 1/ / N S OiV
Phone No.
S_g aL�z�_ ✓- F'J Date : SZ 7 `9
410 a
ie
2i2�Y'32Y'33YYYl YY J ii33Yi3 i333iY3=3 =3.�a Yg Y3YY2i Yai
l {::e} tr_dersta. the ope=atio az_d =ai^t_na=ce p,cc----'':;es estyo7.is:sed in the
z=proved an-4-al- :ras-e rr!�-.agement plazz for the fa_= nas_ed above anal will i..mpliemeat
trese o_ece---u=es. 1 Owe) )co*.F t27,at any additional expa^siori to the existing
desi- Capzcity of the waste t,eat::.e _t ar_c ste_age system or cor_structioa of new
faC'_l; t: es Will resit lyd a r:eu Ce=Ll C t' Q^_ to be SU^CS1tte t0 the �1Vi5i . O
Yr.rizorwe_^_,zl 1� .agewe^_t before the new anL=ais are stocked. i (we) also
understa_ a that there =-st be no aisc:^_a= a of anLmmal -waste free this system to
Surface wa!:ers o% t_ _ State either through a. Ca^_-=ade Co-'.Veya_nce Or t-.=Ou h
r,:nof= f_on a sto= event less severe thazi the 25-yea=, 24-hots stand._ The
app,oved plan, will be f_' z~ at the fa_— ar.e° at t^ office of the 1cca1 Sail and
Water Ccnser-ration Dig t_ ict .
Z;=s of '.:d CW--.&= 'Please P=:.rt)
c
41T
/
'-1
Date: 3--7-7-
(?lease
pr t)
5ignat-uzp Date:
Egte: ek c_hznge i_Z land C'.+T.e�5:'��7 re4':;=?S CCC�_`1G8tiCn or a new ee;tificatioa
(iE the a_c;cved plaaz is cha_*iged) to be su:-'zitted to the Divisi cr- of
�_virGt'=er_ta_ ;��:ageCe^_t with -La 60 days of a title trar•_sfe-.
nmr USE, Glv:r f :i.Cti�ri
ty

NUTRIENT MANAGEMENT PLAN
Grower(s)-
Farm Name:
County:
Production Unit: .
No. of Animal Units:
Type of Waste Facility:
Temporary Storage Period:
Animal Unit Equiv. Live Wt:
Lbs/Animal Unit /Year:
Lbs of Plant Avail. N:
Brown's of Carolina, Inc.
Farm 20 Gilt Finishing
Duplin
Finishing
8000
Anaerobic Lagoon
180 days
135
2.3
18400
This waste utilization plan is based on the following fields, soil types, and crops. If this
information should change, please contact the Soil Conservation Service or Brown's of
Carolina , Inc. so that a new plan can be written .
�r#]
Field #
Soil
I
Crop
Yield/AC
lbs N/unit
Acres
Ibs N
Time to
Type
Code
Required
Apply
1 Blanton
C
5.5
50
2 Autryville
C
6
50
1 Blanton
J
40
2.4
2 Autryville
J
40
2.4
40 11000 Mar -Oct
4500 Mar -Oct
40 3840 S-April
15 1440 S-April
0�
--- ---
----- --------------------------------------------------
---------------
---------------------Total
��_20780
Available
N 18400
*Difference
-2380
A.
Barley (1.6 lb N/bu)
I.
Oats (1.3 Ibs N/bu)
B.
Bermuda Grazed (50 Ibs N/ton)
J.
Rye (2.4 Ibs N/bu)
C.
Bermuda Hay (50 Ibs N/ton)
K.
Sm. Grain Grazed (100 Ibs N/ac)
D.
Corn Grain (1.25 Ibs N/bu)
L.
Sm_ Grain Hay (133 Ibs N/ac)
E.
Corn Silage (12 Ibs N/ton)
M.
Grain Sorghum (2.5 Ibs N/cwt)
F.
Cotton (0.12 Ibs N/Ibs lint)
N.
Wheat (2.4 Ibs N/bu)
G.
Fescue Grazed (50 Ibs N/ton)
H.
Fescue Hay (50 Ibs N/ton)

* A negative number reflects the total number of Ibs of additional N needed to achieve
yields on acreage shown in chart. A positive number means additional land is required
to utilize the N produced by the animals.
This nutrient management plan has been specifically developed for this swine operation.
The plan is based on the soil types, crops to be grown, and method of applicdation for
this particular operation. The waste must be land applied at a specified rate to prevent
pollution of surface and/or ground water. The plant nutrients in the animal waste should
be used to reduce the ammount of commercial fertilizer required for the crops where the
waste is to be applied. This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle and annual soil tests are
encouraged so that all plant nutrients can be balanced for realistic yields of the crop to
be grown.
Several factors are important in implementing this nutrient management plan in order to
maximize the fertilizer value of the waste and to ensure that it is applied in an environment-
ally safe manner. Always apply waste based on the needs of the crop to be grown and the
nutrient content of the waste. Do not apply more nitrogen than the crop can utilize. Soil
types are important as they have different infiltration rates and leaching potential. Waste
shall not be applied to land eroding at greater than five tons per acre per year. Do not
apply waste on saturated soils or on to land when the surface is frozen. Either of these
conditions may result in runoff to surface waters. Wind conditions should also be
considered to avoid drift and downwind odor problems. To maximize the value of
nutrients for crop production and to reduce the potential for pollution, the waste should
be applied to a growing crop or not more than 30 days prior to planting. Soil incorporation
of waste will conserve nutrients and reduce odor problems.
The acres needed to apply the animal waste is based on typical nutrient content for this
type of facility. Annual acreage requirements may be more or less depending upon the
waste analysis report for your waste management facility.
Additional Comments:

Prepared by:
Concurred in by
Producer
Title: _ Date: 97
►im
Date:
I understand that I must own or have access to equipment , primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This
equipment must be available at the appropriate pumping time such that no discharge
occurs from the lagoon in a 25-year 1 -day storm event. I also certify that the waste
will be applied on the land according to this plan at the appropriate times and at rates
which produce no runoff.
Date:.Z��S'
roducer
Date:
T c nicaI Sp i Eist

., �� , ;(, ,yl, p ari I! '1.c�� y'1i, �.r',' r' r" •+M•r�'��
... * Y} • 1 �'/ ,far � ,as �*,�1Frtr ,� r-.,� L F w �"i, + � i i �, � w+«r"•"� •• �. wy,5•, �� �t '.!, .! ..
� , �S-• r,�Y, � � � �' � w , � � : ',,�y ,� n. , � �y.4� M v."R y-� .rrr�,M�
�'�•"s.li•XA" x� l�'. :i • � 1 � ' ,h ,r. �/4 � • F+r j
��� ?r�• �5•i �, + j�N.yi, ., •v }vy <^::'r Ar• 'fit %"� - • "' i1 + +$I} '� ! f r ;'f` `�•y�,�• �w
n' .
X �
\ � � * Vim• .� r Y *, e � � `:� ►. '4' • - �� Iy' . J� � • f i * ,�j
oo
or. V' w r ?., y� i� , • ,j 4:*S i
41 lb,
�Y oK'+.`
Vol
tiV1r ��„5i I.it R� rr+
y #,.
t4'. •� 'A ti i •�. i"'� 'err r
'mow f�"/1 �ij �•'t' r 1r r

N
I ...
40
IF I
56A
7,85
NNi
-t, y r, rj JjLfir. .
F A
al
ON'
E�'
�, •; �!, 7!,Rp r �yy ,. Y
PAO
1.3 -1 J
-9,3 1 6
'W4
. . ?

N-RCS WASTE UTILIZATION
PLANT SPECIFICATIONS
1. . :=al waste shall not reach szria= waters of the state by runoff, Brit, niarunade conveyances, direct application, or
direct discharge dur•:ag operation or land application. A.zv discharge of waste which reaches surface water is
p robl b ited_
2. Taerc must be doc=eatatioa is the desi folder that the producer either owns or has a notarized azrec-meet for use
of adequate lame on w'lsieh to properly apply the waste. If the producer does not otGn adequate land to properly
dispose of waste, hershe shall prm'ide a copy of a notarized agree nent with a landowner who is within a reasonable
proximity, allowing him/her the use of the lard for waste application. It is the responsibility of the owner of the
facility to see :re an update of the Waste Utilization Plan when there is a chance in the operatton, increase in the
number of annals, r aethod of udlizatiou, or available land.
3. t nit -.sal waste shall be applied to meet, but not exceed, the Nitrogen nerds for realistic crop yields based on soil type,
available moisture, historical data, climate conditions, and level of management. unless there are regulations that
resu:e: the rate of application for odher nutrients. Actual vielJl. may be use -I to lieu of realistic yield tables at the
discretion of the planner:
4. Azu nal waste shall be applied on ia_^.d eroding Iess than 5 tots per acre per year. Waste may be applied to lard that
is eroding at r-ore than 5 tons but less than 10 tons per acres per year providiu:., grass titter Strips are installed wise: e
runoff leaves ti e fieid. (Se_ FOTG Star dard 393-FiIter Strips)
5. Odor can be reduced by injecting the waste or erisl ing ^*rr waste application. �'va_;te sllaulc: rut bz applied wacz
the-. a is denge: of dr-ift I om the irrigation field.
6. When anisssal waste is to be applied on acres subject to flooding, it will be a«iI ircorporater on conventionally tilled
cropland. When applied to cats..: v ation tilled crops or gas land, rite wrise may be broadcast provided the
application does not occure during a season prone to flooding. (Se=' 'Wise -Zither and Climate in Norm Carolina" for
grid nnc; .)
7. Liquid waste shall be applied at rates not to exceed the sail itu`Itration rate such that runci: does not occure off -site
or to surface waters a-ld in a method which does not cause drill from; thin :ire awing ippticai:on. No ponding should
occur in order to cor,t-or.,odor and ;lies.
8. p^.� :cal waste shall net be applied to saturated soils, during rainfail events. or when the sui-acr is frozen.
9. Aidmal waste should be applied on actively Fowing crops in such a marmcr that the crop is not coveted with waste
to de- th L' at would prohibit growth. The potential for salt dimaLt rrom anh-al wasrc should also be considered.
10. Waste nutrie-Ls s:-.all not be applied in fall or winter for spring planted crults on .oils with a hid^. potential for
lcacl-L-ia. waste rts::-;mot loadin-z rates on these soils should be held to a minimum and a suitac+ie wi- ter cover crap
plane~ to tali: up release„ -'A nucients. Waste s al: not be app;icd moo- than 0 dax; prim -to planting of a crop or
Lora_es breasting dornaacy.
11, Az y new swi:,e facilir•r sited on or after October 1, 1995 shall comply with the folkiwirg: The outer perimeter of
dhe la:.d area onto whit:, waste is applied frorn a lagoon that is a eornponer of a swine farnm shall be at least 50 feet
Lrorn any resi6endal proper;; bounden and Ecm any per cruiial st:•cans or river other than an irricatien ditch or
cxnal. A.nirnal waste other than s•-zr.e waste fl-orn facilities sited on or after October 1. 1993, shall not be applied
close-. Lhan 25 feet to sixtace water. This dis:w.ce may be redieted for %vat%-rs that un: nut per=rsi_l provided
acre . to ve_c ati•: a ;inter strips are print (Sae Standard 39 : - Files -Swills).

I -RCS WASTE UTILIZATION
PLAN SPECIFICATIONS
(COyTTINVED)
12. P..d- .al w ask shalll not be appT ed close. than 100 feet E-am wells.
I3. AnL-al wasW s1falI act be applied close. than 200 feat of dwellings other tlnatl th[,se o%%,icd by landowner.
i=. Wase shah be applied in a manner not to reach other propelti• and public r;_,lit-of-ways.
15. peal was' . shall not be discharged into surface waters, drainacreway5 or wetlands by a discharge or by over-
sprarmz. Animal waste may be applied to prior conve .ed cropland provided it has been approved as a land
application site by a "izchaical sp�—_ialist". Ari nal waste applied on grassed %vaterways shall be at agronomic rates
and in a maaaer that causes no runoff or drift from the sir_.
16. Domestic and industrial ware from washdown facilities, shuxv_- •s, toilets. sulk., etc., shall not be discharged into the
and raI waste Wanag=ert system.
17. A protective cover. of appropriate vegetation will be established Lin all disturbed areas (lagoon a ;:bar!e-nents,
beams, pipe r-,-s, etc.). Areas shall be fenced, as necessm-v. to proccct the vegetation. Vegetation Such as gees,
si^r%;bs, and oche: wocdti species, etc. are 1;_=`en' to a_r`as where considered apprupriat_. Lagoon areas should be
ke?t mowed — -d ac: essible. La_oon beratis _:d structures sliould be lilal�r tt�' � regularly for of erosion,
leakaK,, or disc: arge.
18. L`a:_ma! prceuction at t1:e facility is terrain ated, dhe owner is respot:;ibIc tier ubrainiiia and irnple- entirg a "cIosur:
pl=* which will eliminate the poss:bilir: of ar. illegal discharge, P0j!i:ti[,il and elk:•iuil.
1 g. Waste handli-ig structures, piping, pwmps, reels, etc., sbou'ld he ins-pe'_ted on n r=^-::lar basis to pre:-eni breakdow-.s,
leaks, and ,-.Ills. A regular inai-^-te:iance checklist s1hou'ld be k:.-pt on site:. -
20. A:s.:.al w'a5 can be used in a r otation that inclvdes vegttalrlez aIld office C70021 for dire::[ human consu'rnp tics.
However, it arl-nal waste is used on cops for di ect 11L'.r :ail :l [7nly he applied prepiant wiLh no
fiiru cr applicatiers of annirnal waste during the crop seasini.
21. Fiig:'_y visialt pe-:a.^enet markers shall be ::stalled to mark the cup and boaum e!,:vatiors of the temporw7 storage
ova:-vi-ig voiu:ne) of all -.mast-- treat--aent lagoons. Purrnping shall be nianage•J to maintain. the liquid love! berhera
tht r-markers. A r.Iarker will be reviled to ma.-k the maxii-mill snn•act v olunle tier waste storage ponds.
22. Soil test; shall be .made eve:y yea_-, and a licuic waste ar_alvsis shall be :z-kta within 60 Lags of aculication
ecr-s.sZent wit.". was:-- utilization pian. Poult-i line' Shall bt feStC'' iii'h�r tt, ,.1111lic:ILI- Soil and waste analysis
rec..^rds shall be for five years_ -
Dead animals will be disposed cf in a riar•:er -.lint me :, NG' re,u!atintss.

EMERGENCY ACTION PLAN
PHCNTE N7RNMERS
DWQ giro - 3 SS-3So 0
E'-'YIERGEN'CY MANAGEMENT SYSTEM 911
SWCD
N-RC S
--This plan will be implemented in the event that wastes from your operation are iealang,
overflowing, or running offsite. You should not wait until wastes reach surface waters or Ieave
your property to consider that you have a problem. You should make every efr'ort to ensure that
this does not happen. This plan should be posted in an accessible location for all ernplovees at the
faclz ity. The following are some action items you should take.
1. Stop the release of wastes. Depending on the situation, this may or may not be possible.
Suggested responses to some possible problems are listed below.
A. Lagoon over�ow--possible solutions are:
a_ Add soil to berm to increase elevation of dam.
b. Pump waste to fields at an acceptable rate.
c. Stop all flows to the lagoon unam, ediately.
d. C2?1 a pumping contractor.
e. Make sure no sur*;ace water is entering lagoon.
B. Runofr from waste application field -actions include:
a. 1r,.mediately s`op waste application.
b. Crete a temporary diversion to contain waste.
C. Incorporate waste to reduce runoff•.
d. Evaluate and eliminate the reason(s) that caused the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle pump.
b. Stop irrigation punp
c. Close valves to edminate further discharge.
d. Repair all leaks prior to restarting pumps.

D. Leakage from flush systems, houses, solid separators -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure no siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
e. Repair all leaks prior to restarting pumps.
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed to flowing
leaks -possible action:
a. Dig a small well or ditch to catch all seepage, put in a submersible pump, and pump
back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and ftil holes and
compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon bottom as soon
as possible.
2. Assess the- .extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what duration?
c. Any damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill Ieave the property?
e. Does the spill have the potential to reach surface waters?
f Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off of the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours, call your DWQ (Division of Water Quality) regional office;
Phone After hours, emergency number:'?/1-?!3-.,'g4lj . Your phone call
should include: your name, facility, telephone number, the details of the incident from item
2 above, the exact location of the facility, the location or direction of movement of the spill,
weather and wind conditions. The corrective measures that have been under taken, and the
seriousness of the situation.
b. If spill leaves property or enters surface waters, call local EMS Phone number 911.
c. Instruct EMS to contact local Health Department.
d. Contact CES, phone number ' i/c - 5!,- d 143 , local SWCD office phone number
�1�-L, and local MRCS office for advice/technical assistance phone number
r
4. If none of the above works, call 911 or the Sheriffs Department and explain your problem to
them and ask that person to contact the proper agencies for you.

S. Contact the contactor of your choice to begin repair cf problem to minimize off -site damage,
a. Contractors Name:
b. Contractors Address:
c. Contractors Phone:
6. Contact the technical specialist who Icertdfied the lagoon (MRCS, Consulting Engineer, etc.)
a. Name: r vt�+ V ctit (2'7 r � �L c� (� r
b. Phone: Rrc 7(1— ISvd `jrp `J59G- '7c3
7. Implement procedures as advised by DWQ and technical assistance agencies to rectify the
damage, repair the system, and reassess the waste management plan to keep problems with
release of wastes from happening again.

�Itat•Ltlily 11•Iatt,tJct-t�ctlll•.[clltocis .
(cliell: %vlric,l Incillo(l(s) arc beipw intplemented)
J Durial three feet beneatll till: surface of the �fround IVithin 3=1 Itottrs after
i:na�t'Iccl�+c of rile rJcallt. The burial must be at least 300 feet from pay flowing
strealu or public butiv of water.
ltearlcrin, at a fendcriaQ plailt licellserl tinder G.S. 106-163.7
Q Complete b1cineralion
III the case or dread poultry olliv, l,lacia, in a tlispo�ai pit of a size ancl'rlesi�n
allproved by tlic Deijartment of Agrictlltttrc
�1 MY method wllic:h in the professiomil opinion of tllc Stale Velerill.triaet svnt{!cl
make possible the saira,�e of part of .I dc,ul ctnintal's value without endangering
Ilttntau or ;tllilYlal hc;tllh.
alt;ICIIC[1) (Written approval of the State . Vetednariatt (trust be
,sect Control Cliecltli.st For Allilrlal 01'mrat10113
Iin�r, tll Cunlrul IIISCCIs Sill: NJIUVINC V111dit•Y'S
I,lnsil Ci{II{Lfs
�lcculrl{II,IIiuu ursulitls
t,ittullt :�yattaus
CJ ,�II{sll syslcnt is ticsil;llc111uu1 ullcrllt*.:11
suniclen{ly to rell7uvc llcclrnmLlictl stitlds rrllllt
t;allcrs Its designed.
Cl Itenton hridghlu Oracc11u1n1i led Solids ill
LIIg1i1113S 111111 MIS
• �:h15{LII :HIIIIIS
�'Illllllllilt IIILf1t111x, SL'11II11L itilSillY 11111I lll1Y \YI[�fV •
•
tlesl Lrcl:diul; is nitll;trclll to ulillinlFcl:llla '
crllslilll; tlrsulids ttl n liglll{ urlu� inure thlul � - .
~I
II inclles over mart: !Ilan jo% t,rsurrace.
rtic 311ve vet;C1illivc
lilllls�h
iJl cuyillg vct;l:101hill
Iviuin{Ilill veguiativu conllol 7dlllll; hanks ill'
lacomis laid uthcr In111IItrnd menls Ill pvveni
Ilel:nn11daii0tt tlrticovinl; vel,,eii, ivc matter
IdIIn1; wulct's 011;c till imilullllllmcill's Ilerimeter.

wine 1=-arm Wa>~stc Ma1,ntagumcnL Odor Con(I•ol Chc:r dl A
5u1u11 Come liRlt's iu gllllhnl�l 11111u• :;Ilt!illrllllc I'rucll�c�
Fullusll'illl -Mille I11u11ucliull Vel,dalivc or ► coded hullus;
IiCC11111nICIll1L'tl� Ilesl IuilllAl,clllllll IIr1lClILL5; .
Good judl-,1ncni and culnulnu scnso
Animal Ludy sullacci !)illy miluluc-comell ullillulls Dly Ilools
1111101 SillIOLCS
• Wul 11laillau-clivelc111111111's
N11111ull 111lllrs;
Widerers Islc;llcd over Shined flours;
1:1
Fecders ul illl;h cad uf'solid flours;
Cl
Scralle 111,111mc 1111ildllll 1•10111 flours"
Cl
Unilel llrlrlr ve111ilalll111 rur drylill,
MiIIHIIC CilliCL'111111 hlls
• UiulC;
('Iellllerll Illilllllle rellInVill Ily 1111511, Illl JvCllill'LC, '
• I'm dial IllicluM.,11 1lecullillnshion
ur scrllic; '
11
Uutlerllutlr vcllllhalim
W1161+11ilm exhallsi film
• Vlllatilc gases.
_
1'1111 111111111elumue;
Dust
lil'licieui uir nluvcluunl
11.1111111 Sill faces
• I)tlsl
Witsl+dUtv11 Ilumcell El Imps lK1111imals;
Fl
Devil udililives;
rl
1'eciler coveri;
Cl
I°cull llellvcry dowlislluul cl;lcndtas In feeder
covets
flush Ionia
Agiladilu of recycled lagoon
0
Flush 111111, covers;
111111ill While WAS are lilliul,
CI
Nicoll fill lines In ueur hullom iirwnl;s ►viih
unii•si lhnll l wills
1h1s111111cp
Agilatulu tl+ll Inl; ► islumiler
Ll
Uudafluur Illish ►viih luult:111nur willilaiiliu
cilllveyallce
I'il Icchurl;e 1111NIIS
Agilallilli 11rreeycieii iatiu011
I_l
lixlend ieLllllfl;C lill1:5 Ill IIei11' lllllltllll ill'iNls
lilillitl 1Yldle Mils tirc lillllil,
►villt 1fu11•sililloll VC1115
Lill skillum
Al;iilliitin dillini, sllllllt 111lik
1_I
N1111111 Ilnik Cows
filling 111111 drn►vdu►vu
lluisitl+l 1lrlht t ullecliun
• AI;iliiliau 1111ring wnstt:►Yi+ier
U
Ilux nwas ,
ur 11111 llul but;CS
C11llYt:Yl11lCIl
Ab1clt: - I'lavt:111ber It. I'1)6 N90 3..
.

_ _ _ _ _ �,..� �
Suurrt
� ..�YwrWYwr:a. �.�.Wuw.{wbAlwwawsw.�ra
sts Glar.ceA.�.�uwY�l{{ILYaI+r.[WMlil�llllal CH. sRwl»a..ER.�Y�YI.�.la 4wwl■ialJV.r+�w.41w.f
11A1i's Io il'lluhuilt� i]■lua Silt:' perilil: I'rnrlIces
[:nilft
lintf of tirlinllilres III
A Al;i1alinu thidol, wailtmalcr
�
I;xlCllil Ilischill-I;U point 11I like's I1111Icr11G1111
lal;nou
ronveynticc
/
Iagoollllqullllevel
Lal;uon sill laces
Voladic Bus emissions;
I
Printer Ingoun hilllld 0111n1elly;
• liiolol;lcll) ntixiiil;;
1'
Ctmecl lagoon slailnll Imiccllures;
• ABilulll'll
Nihilmum silrraca orca-lo-volmna Min;
_
,
• Miulnlum 1lgillillan lvllcn.11tnnplut;;
CS
NS1:chaulcal nl:rallou; .
Cl
Proveu hiological allllillves
Ilfigitlititi SIu11Il.lcr • 1ligll IIIussulk: agil,•Iliuu; I ilriglamu un thy llitys Willi liillu or no Mod;
Inrcrlcs 9 Wiu11 III ill IIVIllliln1n11 rccommendell nllcratinl; iiressilte;
,) Pump iuluka imir lagoon liquid surfitce;
Cl Pump rrom second -range higoon
NItitiit, c tack ur ilasill • P1110al luierttltial det uulllusiiiun; CI 11n1111111 llr (ItillluVtil IUillllilg;
sill Iilce • lvllxinl; +vllilt; I111111c; CI . Twill. covers;
• Agliallon when emplylnu n nosin snrrttce mnis niwsali(is; .
11 Provell Illillogicu) lul(lilives oroxidanls
Scuhllg hmill Sill liteL'
Pallilil 116crullial 11CC(1IIIIIIIsition;
C)
IsxICIIII 1111111111illu 111111CIs willcroultill hllilld
• Mixinl; IVIlile f111111g; •
IaveI;
• Agilinlon when cllilityiug
n
itemove scllicli Sails regularly
hilnttlrC, siorry Ill' sllull;e
• Agituliou whell Sill calling;
CI
Suil hijeciion ul'simry/51ml es; .
1111in111er oullcls
a Volatile gas ClIllssilms
CI
Wash'resithial miuulrc Rom slircadgr ilflur usc;
CI
l'ruvun biuingicul nlhlillves ar oxldlulis
lhiconfull111,111urC,
0 V111111ilt: I;115 clnlsslulls %Vlliiu
CJ
Soil lnjeclluu of51111rylsiullges
shury or sludge on 11chl
Illying
n
;roll locurh(Ir1 ion within 48 In,;
SIII 111Ce5
El
Spread In Ildil milfurm layers fur ralihl drying;
Cl
Prnveli hlolul;lmd oddillvcs or oxiihmis
I]C111 lildil1i115
■ Calum 11Ccutnho5ilion
holler Ilisposhilill (11'Clac1am:1
Nall Imilu it IIkIll Hill
■ Olicasi 11CCUI1IIlu5iliuu
CI
(.'11111 ilele cuvel ing or CiuCtlises ill hill till 1111s;
Mils
CI
Proper Iuclllimilcmistillclimt urllislmsal lilts
111611cli tills
inI nI11111cII; cutuhustiull
U
Secnn(Illry suick 1111mas
ltNlC]C - Nuvl other i 1,1'}'}il, l'llttiu 4 '

• , • � �.1wwwwl,a� •�C..R'I.C.Y�yI���O-aim.wK�R�d�•4lWYr�.�fw�v�f..'.y,./`��iw:��c��.�•N-c>.RYIO�•1.•��.
S1n+rrr Cuusu IIHII's Its hllnlntlr.0 011111• 51ie :;Lrcllir. i`i:�rllt es
SiilnJUll., wille[ i1111111N1 a 111111111per Iltiiillilge. Urnt1v will huttlicape such 1111t1 lvaier 11rahis
laeilificx mictowni llccomliusitiuit of atv;ly frllnt fildliiies
uri;unic u111iter - '
himmic 1111tAell 111110 • foully mainlitirtctl access lualls Faml access utall u14111cuallcu
ptdlli+ ntinls lirun fnnu - '
1IMSS
Additional lilfominilnrt : Avulluiill l runt ;
Stviue Mituuire hialtoulancnl ; 02011 Itille/11MI, Puckei 11CSI I, C:rinu1y i.xil:tlsi(ii Coder
Stviue: I'nulncllull Fu1111 1'ulc1311ul Odor Sunrees and Itemedles ; 1:11A1i Mid Shed t•ICtiU - I)Alt
Stvlou Prinhicilun INclllty Mimmo M;uuli;cutclli: I'll Itcr.11ori;a - iatl;uon'1'rlatinmil ; FBA1: 129-011 NCSII - IIAF
`:►vine I`I111111C111111 Fildlily M1uimt! M11n11gemeiil: Undcrilunr Hiisli - Impim'1'realnlutil ; FI)AF 129-08 NCSII - I I A H
I.aunnll Doilpl 111111 hl;utnl;cmrnl I'm t.lvesluck Mltnnre'I'lt ilulent Illid Storlign ; FMAIi 107-113 NCSU - ISAI's
Camiraom, orMaunru mid Wasiewaler Appllcaliult Uilulpment ; GIIAIi Fact Shcul NUM - IIA1:
Cuutru11111; Odors front Swille 1111111lirigs ; MU-]] NC II - Stvlua PNICItSluu
Fuvifnomenlul Axsurunce Prui;rom , NI'I'C Manual NC I'alk Products Asstic
I illitluux fur Alantil;hil; Nor; it relim1 irulil the Swine 011ttrTusk Fit= NCSII Agri Comilillnlcttilnns
1.1111r1t1ce Cillicuilis lit Animid Malltire Mautlgemeltl: Odors lied Flies ; i`I10107, 1995 Cunfcruncu i'roccediogs 1 111rlllit Cunituritllvu I:xlcltsltlit
I '
��'t •., IIAll1I; • 1311vt:tttltcr 11,1t1t1fi, 1'ttl;u 5

United States Natural Resources P. O. Box 277
Department of Conservation Kenansville, NC 28349
Agriculture Service Telephone [phone]
March 6, 1995
Mr. Jimmy Vinson
Browns of Carolinas, Inc.
303 E College Road
P. O. Box 487
Warsaw, NC 28398
Dear Mr. Vinson:
Enclosed is your copy of a wetland determination for tract 1617 on which you indicated your
intent to clear some land. The attached map has been delineated to show the area(s) in
question. Each area to be cleared has been identified with a symbol to denote its classification.
Below is an explanation of the various symbols that may pertain to your map.
x NW- Non wetland - Area is non wetland and can be cleared and utilized without
violating Farm Bill. This determination of non wetland is only for Farm Bill purposes.
You may still need US Army Corp of Engineers and Division of Environmental
Management determinations before clearing. The Natural Resources Conservation
Service does not have the authority to make wetland determinations for these other two
agencies.
x W - Wetland - Area is a wetland and should not be cleared for any reason if you
wish to remain eligible for USDA programs, receive NRCS technical assistance, or avoid
violating US Army Corp of Engineers' and Division of Environmental Management
(DEM) regulations. Any exceptions to this statement should be in writing from the
Natural Resources Conservation Service prior to clearing land.
_x— HEL - Highly Erodible Land - Area is highly erodible and should have a
conservation plan developed prior to producing an annual row crop in order to remain
eligible for USDA programs.
This determination is only for the area delineated on the attached map. If you plan to clear
more acreage than that shown on the map, you should request another wetland determination
for that area.
I have tried to make this determination as fairly as possible_ However if you believe this
determination is incorrect, you have the right to appeal. To appeal send me a brief letter
explaining why you believe this determination is incorrect. Send the letter to the address on
the letterhead. This letter should be received within 15 days of your receipt of this letter.
Sincerely,
2hLae E. Su /I
99
District Conservationist
The NaWnd Rcaourcea Conservation Servioe.
formerly the Soil Conservation Service,
is an agency of the
United Stetcx DeparTmcnt of Agricultu
AN EQUAL OPPORTUNITY EMPLOYER

U.S.D.A. " SCS-CPA "16 1 1. Name and Address of Person 2. Date of Request
Soil Conservation Service (jar,
HIGHLY ERODIBLE LAND AND WETLAND
CONSERVATION DETERMINATION
4. Name of USDA Agency or Person Requesting Determination 5. Farm No. and Tract No.
SECTION I - HIGHLY ERODIBLE LAND
3. County
` #
6. is soil survey now available for making a highly erodible [and determination? Yes 0. No 0
RELD NO.(s)
TOTAL ACRES
7. Are there highly emclibie so,: map units on this farm? Yes [j, No ❑
_
8. List highly erodible fields that, according to ASCS records, were used to produce an agricultural commodity in any
crop year during 1981-1985.
9. List highly erodible fields that have been or vAll be converted for the production of agricultural commodities and_
according to ASCS records, were not used for this purpose in any crop year during 1981-1985; and were not
enrolled in a USDA set -aside or diversion program.
. u.
` ` f
10. This Hiolily Erodible Land determination was completed in the: Office ❑ Feld ❑
SECTION 11 - WETLAND
FIELD NO.(sl
TOTAL ACHES
11. Are there hydric soils on this farm? Yes No ❑
12. Wetlands (W), including abandoned wetlands, or Farmed Wetlands (FW) or Farmed Wetlands Pasture (FWP).
Wetlands may be farmed under natural conditions. Farmed Wetlands and Farmed Wetlands Pasture may be
;.. 1
7
farmed and maintained in the same manner as they were prior to December 23, 1985, as tong as they are not
abandoned.
13. Prior Converted Cropland (PC). Wetlands that were converted prior to December 23, 1985. The use, management,
drainage, and alteration of prior convened cropland (PC) are not subject to the wetland conservation provisions unless
the area reverts to wetland as a result of abandonment.
14. Artificial Wetlands (AW). Artificial wetlands includes irrigation -induced wetlands. These wetlands are not subject
to the wetland conservation provisions.
15. Minimal Effect Wetlands (MW). These wetlands are to be farmed according to the minimal -effect agreement signed
at the time the minimal -effect determination was made.
16. Mitigation Wetlands (MI W). Wetlands on which a person is actively mitigating a frequently cropped area or a wetland
converted between December 23, 1985 and November 28, 1990.
17. Restoration with Violation (RVW-year). A restored wetland that was in violation as a result of conversion after
November 28, 1990, or the planting of an agricultural commodity or forage crop.
18. Restoration without Violation (RSW). A restored wetland converted between December 23, 1985 and
November 28, 1990, on which an agricultural commodity has not been planted.
19. Replacement Wetlands (RPW). Wetlands which are converted for purposes other than to increase production,
where the wetland values are being replaced at a second site.
20. Good Faith Wetlands (GFW+year). Wetlands on which ASCS has determined a violation to be in good faith and the
wetland has been restored.
21. Converted Wetlands (CW). Wetlands converted after December 23, 1985 and prior to November 28, 1990. In any
year that an agricultural commodity is planted on these Converted Wetlands, you will be ineligible for USDA benefits.
22. Converted Wetland (CW+year)- Wetlands converted after November 28, 1990. You will be ineligible for USDA
program benefits until this wetland is restored.
23. Converted Wetland Non -Agricultural use (CWNA). Wetlands that are converted for trees, fish production, shrubs,
cranberries, vineyards or building and road construction.
24. Converted Wetland Technical Error (CWTE). Wetlands that were converted as a result of incorrect determination
by SCS.
25. The planned alteration measures on wetlands in fields are considered maintenance and are in compliance
with FSA.
26. The planned alteration measures on wetlands in fields are not considered to be maintenance and if
installed will cause the area to become a Converted Wetland (CW). See item 22 for information on CW+year.
I27. The wetland determination was completed in the office ❑ field El and was delivered❑ mailed❑ to the person on(j-
28. Remarks.
"Refer to Attached Ma.p For Areas
Zy. t cernJy that the above determination is corrert and adequate for use in determining 30. Signature of SCS District Conservationist 132. Date
eligihilin- for USDA program benefits, and that wetland hydrology. hydric soils, and I- Ij
irvdrophytic vegetation under normal vircun+slances exist on all areas outlined as
Wetlands. Fanned Wetlands, and Farmed Wetlands Pasture. 1 '.
a
Assistance and programs of the Soil Conservation Service available without regard to race, religion, oalor, set, age, or hwxk:iqx
Portion Copy

State of North Carolina
Department of Environment, RE
4Health and Natural Resources' MMAI r4i
•
Division of Water Quality �`
James B. Hunt, Jr., Governor L
BY -
Jonathan B. Howes, Secretary
A. Preston Howard, Jr., P.E., Director
July 28, 1997
Jimmy R. Vinson
Farm 90
PO Box 487
Warsaw NC 28398
Subject: Certificate of Coverage No. AWS310678
Farm 90
Swine Waste Collection, Treatment, Storage
and Application System
Duplin County
Dear Jimmy R. Vinson:
In accordance with your application received on July 7, 1997, we are forwarding this Certificate of
Coverage (COC) to Farm No. 31-678, authorizing the operation of an animal waste collection, treatment,
storage and land application system in accordance with the State's General Permit (attached). This
approval shall consist of the operation of this system including, but not limited to, the management of
animal waste from the Farm 90, located in Duplin County, with an animal capacity of no greater than 7200
Feeder to Finish and the application to a minimum of 55 acres of land as specified in the Certified Animal
Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until December 31, 2001. Pursuant to this
COC, you are authorized and required to operate the system in conformity with the conditions and
limitations as specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of
wastes to surface waters. An adequate system for collecting and maintaining the required monitoring data
and operational information must be established for this farm. Any increase in waste production greater
than the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to actual
increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General
Permit or the CAWMP may result in the revocation of this COC.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This
request shall be made within 30 days of notification by the Division.
This COC is not automatically transferable. A name/ownership change application must be
submitted to the DWQ prior to a name change or change in ownership.
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

If any parts, requirements, or limitations contained in this COC are unacceptable, you have the
right to apply for an individual non -discharge permit by contacting the engineer listed below for
information on this process. Unless such a request is made within 30 days, this COC shall be final and
binding.
The subject farm is located in the Wilmington Regional Office. The Regional Office Water Quality
Staff may be reached at [phone]. If you need additional information concerning this COC or the
General Permit, please contact J R Joshi at [phone] ext. 363.
Sincerely,
f
A. Preston Howard, Jr., P.E.
cc: (Certificate of Coverage only for all cc's)
Duplin County Health Department
Wilmington Regional Office, Water Quality Section
Duplin County Soil and Water Conservation District
Permit File

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
June 26, 1998
Brown's of Carolina, Inc -
Farm 90
PO Box 487
Warsaw NC 28398
LT,?W,A
IT
A&4 • 21
- — M Ldwl
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Reissuance of Certificate of Coverage
No.AWS310678
Farm 90
Swine Waste Collection, Treatment, Storage and
Application System
Duplin County
Dear Brown's of Carolina, Inc.:
The Division of Water Quality modified the Swine Waste Operation General Permit originally issued to
this facility on July 28, 1997. In accordance with the issuance of the revised General Permit, we are
forwarding this Certificate of Coverage (COC) to Brown's of Carolina, Inc., authorizing the operation of
the subject animal waste collection, treatment, storage and land application system in accordance with
General Permit AWG100000. This approval shall consist of the operation of this system including, but
not limited to, the management of animal waste from the Farm 90, located in Duplin County, with an
animal capacity of no greater than 7200 Feeder to Finish and the application to land as specified in the
Certified Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003, and shall hereby void
COC No AWS310678 dated July 28, 1997. The COC shall hereby incorporate by reference any specific
conditions of the previous COC issued to this facility. The purpose of this COC is to allow coverage
under the revised General Permit. Please review the revised General Permit (enclosed) and pay
particular attention to Condition II.10 regarding tree removal from lagoon embankments, Condition 111.1
regarding inspection frequency of the waste treatment, storage and collection system and Condition 1I1.6
regarding notification requirements for system failures, spills and emergencies. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations
as specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
Us COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the
General Permit or the CAWMP may result in the revocation of this COC, or penalties in accordance
with NCGS 143-215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive
relief.
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled! 10% post -consumer paper

Certificate of Coverage AWS310678
Farm 90
Page 2
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This
request shall be made within 30 days of notification by the Division.
This COC is not automatically transferable. A name/ownership change application must be
submitted to the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the
right to apply for an individual non -discharge permit by contacting the engineer listed below for
information on this process. Unless such a request is made within 30 days, this COC shall be final and
binding.
The subject farm is located in the Wilmington Regional Office. The Regional Office Water
Quality Staff may be reached at [phone]. If you need additional information concerning this
COC or the General Permit, please contact Katharine Keaton at [phone] ext. 533.
Sincerely,
for A. Preston Howard, Jr., P.E.
cc: (Certificate of Coverage only for all cc's)
Duplin County Health Department
Wilmington Regional Office, Water Quality Section
Duplin County Soil and Water Conservation District
Pennit File

State of North Carolina IT 2J
Department of Environment, ffl�,�VA
Health and Natural Resources 4 0
Division of Water Quality
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary ED E H N F1
A. Preston Howard, Jr., P.E., Director
June 11, 1997
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Brown's of Carolina
Farm 90
PO Box 487
Warsaw NC 28331
Farm Number: 31-678
Dear Brown's of Carolina :
You are hereby notified that Farm 90, in accordance with G.S. 143-215.1OC, must apply for
coverage under an Animal Waste Operation General Permit. Upon receipt of this letter, your farm has
thirty (30) days to submit the attached application and all supporting documentation. In accordance
with Chapter 626 of 1995 Session Laws (Regular Session 1996), Section 19(c)(2), any
owner or operator who fails to submit an application by the date specified by the
Department SHALL NOT OPERATE the animal waste system after the specified date.
Your application must be returned within thirty (30) days of receipt of this letter. Failure to submit the
application as required may also subject your facility to a civil penalty and other enforcement actions for
each day the facility is operated following the due date of the application.
The attached application has been partially completed using information listed in your Animal
Waste Management Plan Certification Form. If any of the general or operation information listed is
incorrect please make corrections as noted on the application before returning the application package. The
signed original application, one copy of the signed application, two copies of a general location map, and
two copies of the Certified Animal Waste Management Plan must be returned to complete the application
package. The completed package should be sent to the following address:
North Carolina Division of Water Quality
Water Quality Section
Permits and Engineering Unit
Post Office Box 29535
Raleigh, NC 27626-0535
If you have any question concerning this letter, please call John Jallah at [phone] extension
364 or Dave Holsinger with the Wilmington Regional Office at [phone]
Sin ly, �
A. Preston Howard, Jr., P.E.
cc: Permit File (w/o encl.)
Wilminb on Regional Office (w/o encl.)
P.O. Sox 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

State of North Carolina
Department of Environment,
Health and Natural Resources 1 •
James B. Hunt, Jr., Governor ------------------ ------
Jonathan B. Howes, Secretary p E H N FR
November 12, 1996
Brown's of Carolina Inc
Farm 90
PO Box 487
Warsaw NC 28331
SUBJECT: Operator In Charge Designation
Facility: Brown's of Carolina Farm 90
Facility ID#: 31-678
Duphn County
Dear Farm Owner:
Senate Bill 1217, An Act to Implement Recommendations of the Blue Ribbon Study
Commission on Agricultural Waste, enacted by the 1996 North Carolina General Assembly,
requires a certified operator for each animal waste management system that serves 250 or more
swine by January 1, 1997. The owner of each animal waste management system must submit a
designation form to the Technical Assistance and Certification Group which designates an
Operator in Charge and is countersigned by the certified operator. The enclosed form must be
submitted by January 1, 1997 for all facilities in operation as of that date. Failure to designate a
certified operator for your animal waste management system is a violation of 15A NCAC 2H
.0224 and may result in the assessment of a civil penalty.
If you have questions concerning operator training or examinations for certification, please
contact your local North Carolina Cooperative Extension Service agent or our office.
Examinations have been offered on an on -going basis in many counties throughout the state for
the past several months and will continue to be offered through December 31, 1996.
Thank you for your cooperation. If you have any questions concerning this requirement please
call Beth Buffington or Barry Huneycutt of our staff at 9191733-0026.
Sincerely,
A Preston Howard, Jr.,.� , i�firector
Division of Water Quality
Enclosure
cc: Wilmington Regional Office
Water Quality Files
P.O. Box 27687, N_yamC FAX [phone]
Raleigh, North Carolina 2761 1-7687 An Equal Opportunity/Affirmative Action Employer
Voice 919-715-4100 50% recycled/ 100% post -consumer paper

=r VMS__ tiLl*�'� PLAM CMR== C:A"N POR 5N3?i OR =?A rZ= P'_0M=TS
Please retw=M the cc=plat6,- fn== to the Div-iaia: Of at
C
the adWass On the rePQ=s• a,{.da of th_4 J f4�.
f l tName [,�,.L /A/rtji'/ tj
Addess '4 cX 7 -
Phone No Y/r^� � ` ��r(I
�`
,� Fa ? o—ticn: Latitude ar_d Lonsitudei� `` § 5 29 —7
please actach a capy of a COMM, road tap with location identified.
T 7e of operation (s-air_e, layer, daisy, etc.)
Design capacity (nL=ber of ZMAIM 1 S) $ 0wo
Average site of cpe-at:�c- (1.2 mcnzh.rcoulatiaa avg.) 72(20_ !'-
Average acreage needed for land application of waste (awes) : 5� `'
0 =iI
333333373��L3�S`J��i�i3�;+33i7�sii=iii3 iii 3i 3'�`j33�133 iJ 3�3S 333333 i3iii7�ii�337i� �r
t - -�
Ted.�ca1 Spec± s? iat Ca��if_Bata aa�+
==
As a technical s—peciaiist designated by the Norte. Carolina Sail and out �
Conservation Commission, puz-sLam, to ISA NCAC 6r .0005, 1 certify t.`+..at the new4f �
expzeded animal wastemanagement system as installed far the fa_'Z nailed abc4e,c
has am a*._czi caste r, a:.ace=e_zt plan: that meets the design,
operationa^ �a�-:tera^_ce star^.cards a: = specifications of the iNV±sion
zhvizor=e_ntal management and the 75DA-Soil Conservation service and/or the North 2
17F�
Caz-oli^a Soil nd Hater Conservation Ca=issicn to 15A NCAC 2z.0217 and J✓'
_pursuant
WA NZ!C 6s .0001-.0005_ The following elements and their corresponding m zzim= �J�d
i Z_5-o
crit`e_ia-haz bee verified by me or other designated technical specialists and
are included in the plan as applicable: min_rum separations (buffers); liners or
equivalent for lagoons a_ waste storage ponds; waste storage capacity; adequate
quantity and amount Of land for waste utilization (or use of third pazty) ; access
or ownership of proper waste application equipment; schedule for timing of _
applications; application rates; loading rates; and the control of the dischaz-ge
of pollutants from stogywater runoff events less severe than the 25-yea=, 24-hour
star=.
Nara of Tach: ical specialist (Please
Affiliation: 121, 41.5 14 / i
Address Oct Q7 , ony ;.
Intl • - 111W ( V iAISod
Phone No. -� 4g
Date:--27-14-
II
��ea�s==�Lr:ars s+ ���:�a�:a�=s:aa a�xr�ssasa�easzaaaa�s=s=asaa aas=sm=as3aa�r�
( a) ur_derst the operation and maintera^_ce procedures establishes? in the
aoorone a.^_inal waste *- Tag. eme_^.t plate for the farm named a:rove and will implement
Chese p _cceh es. 2 (we) know. that any addiKonal expansion to the axistimg
design capacity of the waste t=eatt<ent and storage systeat or ccrstruction of new
facilities will require a new certification to be submitted to the Division of
=.nvirc= ental y_an^.aceme_n.t before the new aaQlals are stocked. I (we) also
understand that there must be no discharge of animal waste from this system to
surface waters of the state either through a man-made conveyance or through
runoff from a storm event less severe than the 2S-year, 24-hart; stars.. The
approved pla*i will be filed at the farm anal at tlhns� office of the local Sail and
Water Conse_ration Disc;ict. �-
�
Na=.e of `mod C v-_.r Please Priest )
3'_,7-7-/T
� � U
Hasa of y gsr, _f different Erc= Owner (Please print) :
Sig :attre: - Date:
A c�:anga, i^z JaLr_d-bwmershjip requires notification or a new certification.:_
(if the approved plats is cLanzged) to be su!: itted to She DivisicM Of
, Zv-_tor=e _cal Management on? r ; n 60 days of a title transfer .
-i"1..e-• r. ..1/�7:w .,w--�- r2 v.r-;�.i-1��L •r.r S'7L�� -3V.

BRowN�s
OF NA
BROWN'S OF CAROLINA - FARM #20 GILT FINISHING
9 (800) FEEDER TO FINISH
STATE ROAD #1105 - DUPLIN COUNTY
1.2
w
t .3 FAil.V 4 2 F-S
L-- 1371
ULL LZ
r ro-
3d- 7,
ilm LI-11 um F�E? I
lie
lua Mt
Ila LU4 AQ
J.A
'Fit
MCO-�OLU
POP. J rz
2-7
.A
DIRECTIONS: FROM WARSAW, TAKE HIGHWAY #20 TOWARD CLINTON.
TURN LEFT ONTO STATE ROUTE #1105. AFTER APPROXIMATELY 4 MILES TURN
RIGHT AT CARLTON CHAPEL. FARM WILL BE APPROXIMATELY 0.25 MILES ON
RIGHT.
MAILING ADDRESS:
BROWNtS OF CAROLINA
P.O. BOX 487
WARSAW, NC 28398
WORK: [phone]
SIUPPE*-;G ADDRESS:
BOC #20 FINISHING
STATE ROUTE #1105
WARSAW, NC 28398
BROWN'S OF CAROLINA, INC.
303 FAST COLLEGE STREET - P.O.BOX 487 - WARSAW, N.C. 2839M487 - OFFICE: [phone] - FAK- (910) 293-A726