310378_HISTORICAL_20171231

NUH I H UAHULINA
Department of Environmental Qual

-AM; .
NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Resources
Water Quality Programs
Pat McCrory Thomas A. Reeder
Governor Director
August 29, 2013
Thomas J. King
King Pens
164 Eneas Lanier Road
Chinquapin, NC 28521
John E. Skvarla, III
Secretary
Subject: Certificate of Coverage No. AWS310378
King Pens
Swine Waste Collection, Treatment,
Storage and Application System
Duplin County
Dear Thomas J. King:
In accordance with your August 28 request to change operation type without exceeding the permitted
steady state live weigh, we are hereby forwarding to you this Certificate of Coverage (COC) issued to
Thomas J. King, authorizing the operation of the subject animal waste management system in accordance
with General Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for the King Pens, located in Duplin County, with a swine animal capacity of no greater
than the following annual averages:
Wean to Finish: 2723 Feeder to Finish: Boar/Stud:
Wean to Feeder: Farrow to Wean: Gilts:
Farrow to Finish: Farrow to Feeder: Other:
If this is a Farrow to Wean or Farrow to Feeder operation, there may be one boar for each 15 sows. Where
boars are unnecessary, they may be replaced bey+ an equivalent number of sows. Any of the sows may be
replaced by gilts at a rate of 4 gilts for every 3'sows. '
The COC shall be effective from the date of issuance until September 30, 2014, and shall hereby void
Certificate of Coverage Number AWS310378 dated August 21, 2013. Pursuant to this COC, you are
authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Please nav careful attention to the
record keeping and monitoring conditions in this permit. Record keeping forms are unchanged with this
General Permit. Please continue to use the same record keeping forms.
ECEIVE
1636 Mail Service Center, Raleigh, North Carolina 27699-1636 EP 0 q�
Location: 2728 Capital Blvd., Raleigh, North Carolina 27604 SL
13
Phone: [phone] FAX: [phone]M 4 Customer service: 1-877-623.6748
Intemet: www.nowaterquality.org BY:
An Equal Opportunity L Affirmalive Action Employer

M
If your Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Per 15A NCAC 2T .0105(h) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100-foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties; criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, then an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Unit for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition 11.22 of the General Permit, waste application shall cease within four. (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Tropical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You
may find detailed watchlwaming information for your county by calling the Newport/Morehead City, NC
National Weather Service office at [phone], or by visiting their website at:
www.erh.noaa.jzov/er/mhx/
This facility is located iQ a county covered by our Wilmington Regional Office. Toe Regional Office
Aquifer Protection Staff may be reached at [phone]. If you need additional information
concerning this COC or the General Permit, please contact the Animal Feeding Operations Unit staff at
[phone].
Sincerely,
for Thomas A. Reeder
Enclosure (General Permit AWG100000)
cc: (Certificate of Coverage only for all ccs)
Wilmington Regional Office, Aquifer Protection Section
Duplin County Health Department
Duplin County Soil and Water Conservation District
APS Central Files (Permit No. AWS310378)
AFO Notebooks
Murphy -Brown, LLC

WASTE UTILIZAT 6i4 -PLAN
PRODUCER: Genesis Farm; Dontor Inc.
LOCATION: 368 Eneas Lanier Rd
Chinquapin, NC 28521
TELEPHONE: [phone]
TYPE OPERATION: Farrow - Feeder
NUMBER OF ANIMALS: 600
(Design Capacity)
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface and/or groundwater. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops in the fields where the waste is
to be applied. This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle. Annual soil tests are strongly encouraged so that all
plant nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and available water holding capacities. Normally waste shall not be applied to land
eroding at greater than 5 tons per acre per year. With special precautions, waste may be
applied to land eroding at up to 10 tons per year. Do not apply waste on saturated soils, when it
is raining, or when the surface is frozen. Either of these conditions may result in runoff to
surface waters which is not allowed under DEM regulations. Wind conditions should also be
considered to avoid drift and downwind odor problems. To maximize the value of nutrients for
crop production and to reduce the potential for pollution, the waste should be applied to a
growing crop or applied to bare ground not more than 30 days priorlantngInjege
waste or disking will conserve nutrients and reduce odor problems.
JUL 2 0 2009
BY:
The estimated acres needed to apply the animal waste is based on typical nutrient con ent-for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for analysis.
This waste utilization plan, if carried out, meets
21-1.0217 adopted e_ r�wron�m�pt��lVlat
JUL 16 2009
requirements for compliance with 15A NCAC
nt Commission.
RECEIVED 1 DENR 1 DWQ
Aquifer I'mtertian Section
JUN 12 2009
1

WASTE UTILIZATION PLAN
Amount of Waste Produced Per Year (gallons, ft. tons, etc.)
600 animals X 3861 (gal) waste/animal/year =
Amount of Plant Available Nitrogen (PAN) Produced Per Year
600 animals X 6_5 lbs. PAN/animal/year
Guide Std. 633)
2,316,600 (gal) waste/year.
3,900 lbs. PAN/year. (PAN from N.C.
Tech
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner
The following acreage will be needed for waste application based on the crop to be grown and surface
application:
Table 1: ACRES OWNED BY PRODUCER
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
# No. Tvpe Per Acre Utilized Application:
71951
1
FoA
Bermuda G
255
4.081
1040.4
March - Sept
71940
1
Ra
Fescue G
190
3.92
744.8
Feb-June/S-Nov
71940
2
Ra
Bermuda G
190
8.97
1704.3
March - Sept
-1 &-2
Small Grain
50
13.05
652.5
Sept - April
0
0
0
0
0
0
0
0
i otal 1 16.971 4,142.UU I
`This N is from animal waste only. If nutrients from other sources such as commercial fertilizer are
applied, they must be accounted for.
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N requirements.
Beginning in 1996 the Coastal Zone Management Act will require farmers in some eastern counties of
North Caroline to have a nutrient management plan that addresses all nutrients. This plan only
addresses Nitrogen.
A�451 �Su[ y 3�
}i 1�
Page 2

WASTE UTILIZATION PLAN
Table 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowner must be attached)
(Required only if operator does not own adequate land [see
Required Specification 2])
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
* See footnote for Table 1.
Totals from above Tables
Acres Lbs. N
Utilized
Table 1 16.97 4,142
Table 2 0.00 -
Total 16.97 4,142
Amount of N Produced 3,900
Surplus or Deficit 242
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to prevent over
application of nutrient or other elements.
Page 3

WASTE:UTILIZATLON -PLAN `�
See attached map showing the fields to be used for the utilization of waste water.
Application of Waste by Irrigation
Field Soil Type Crop Application Application
No. Rate (IniHr) Amount (in.)
1
FoA
Bermuda
0.5
0.5
1 &2
Ra
Pasture
0.4
0.5
THIS TABLE IS NOT NEEDED IF WASTE IS NOT BEING APPLIED BY IRRIGATION, HOWEVER A SIMILAR TABLE
WILL BE NEEDED FOR DRY LITTER OR SLURRY.
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 MONTHS. In no instance should the volume of
waste being stored in your structure exceed Elevation' *19" freeboard as per lagoon gauge -
Call the local Natural Resources Conservation Service (formerly Soil Conservation Service) or Soil
and Water Conservation District office after you receive the waste analysis report for assistance in
determining the amount per acre to apply and the proper application rate prior to applying the
waste.
Narrative of operation: The acreage used in this plan is the effecitive "wetted" area from the
irrigation design. Tract 71940 will be in Fescue and the other two tract will be in bermuda which
will be overseeded with small grain in the winter.
Page 4

WA$TEUTILIZATION� P ;LAN
M,. _
REQUIRED SPECIFICATIONS -
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of waste, he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner of the facility to
secure an update of the Waste Utilization Plan when there is a change in the operation,
increase in the number of animals, method of utilization, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climatic conditions, and level
of management, unless there are regulations that restrict the rate of application for other
nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but less than 10 tons per acre per
year providing grass filter strips are installed where runoff leaves the field.. (See FOTG
Standard 393 - Filter Strip).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6 When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland,
the waste may be broadcast provided the application does not occur during a season
prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order to control odor or flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
Page 5

WASTE-WILIZATIQN PLAN.
REQUIRED SPECIFICATIONS
(continued)
Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a
high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste
shall not be applied more than 30 days prior to planting of the crop or forages breaking
dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and from any perennial stream or river (other than an irrigation ditch or canal. Animal
waste other than swine waste from facilities sited on or after October 1, 1995), shall not be
applied closer than 25 feet to' perennial waters. (See Standard 393 - Filter Strips).
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those owned
by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site by a "technical specialist".
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
Page 6

WASTE UTILIZATION ,PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced as necessary to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied pre -plant with no further applications animal waste
during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste analysis records shall be kept
for five years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
23
Dead animals will be disposed of in a manner that meets North Carolina regulations.
Page 7

WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: Genesis Farm
Owner/ Manager Agreement
I (we) understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. I (we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new facilities will require a new
certification to be submitted to the Division of Environment Management (DEM) before the
new animals are stocked. I (we) also understand that there must be no discharge of
animal waste from this system to surface waters of the state from a storm event less
severe than the 25-year, 24-hour storm. The approved plan will be filed on -site at the farm
office and at the office of the local Soil and Water Conservation District and will be
available for review by DEM upon request.
Name of Facility Owner:
(Please print)
Dontor Inc.
Signature:Date:
Name of Manager (If different from owner):
Jose Luis Torres
Signature'Date:
Name of Technical Specialist: (Please print) Toni W. Kin
Affiliation:
Address (Agency):
Murphy - Brown
P.O. Box 856
Warsaw, NC 28398
Signature'— Date: l Imo-` C�
Page 8

Aerway
The following table is to be used when irrigation is done with the "Aerway" irrigation system. The
acreage used is the total field acreage minus the acreage claimed on page 2 of this NUP, as this
system wets the entire field.
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
# No. Type Per Acre Utilized Application
71951
subfield 1
FoA
Bermuda G
255
4.32
1101.6
March - Sept
71940
subfield 1
Ra
Fesce G
190
4.58
870.2
Aug1 - July 31
71940
subfield 2
Ra
Bermuda G)
190
5.63
1069.7
March - Sept
-1 &--2
Small Grain
50
9.95
497.5
Sept - April
0
0
0
0
0
0
0
0
Total , 14.531 3,539.00 1
*This N is from animal waste only. If nutrients from other sources such as commercial fertilizer are
applied, they must be accounted for. N must be based on realistic yield expectation_
NOTE: The applicator is cautioned that P and K may be over applied while meeting the iV
requirements. Beginning in 1996 the Coastal Zone Management Act will require farmers in some
eastern counties of North Caroline to have a nutrient management plan that addresses all nutrients.
This plan only addresses Nitrogen.
Owner 1 Manager z
Technical Specialist
Date
1:A1�-c 10-:�
Date '
Page 1

Waste Management Plan Changes
Facility Farm �Y1e5 l S W
o
This farms Waste Management Plan has made the following changes:
❑ Crop changes
❑ Wetted Acres
❑ Increased Acreage
❑ Decreased Acreage
❑ Changed Irrigation Design
❑ Change in Farm type
❑ Plan based on 3 Years On Farm Records
❑ Other
Comments:
•t-- �� 5 Cj4Orr,
�Lu o u
Date

Murphy -Brown, LLC 3/20/2006 2822 Hwy 24 West
P.O. Box 856
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Grower(s):
Farm Name:
Dontor Inc. 31-378
Genesis Farm
County: Du lin
Farm Capacity:
Farrow to Wean
Farrow to Feeder 600
Farrow to Finish
Wean to Feeder
Feeder to Finish
Storage Structure: Anaerobic Lagoon
Storage Period: >180 days
Application Method: Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, W, tons, etc.):
Capacity Type - Waste Produced per Animal Total
Farrow to Wean
3212 gallyr
gallyr
600
Farrow to Feeder
4015 gallyr
2,409,000 gallyr
Farrow to Finish
10585 gallyr
gallyr
Wean to Feeder
223 gallyr
'gallyr
Feeder to Finish
986 gallyr
gal/yr
Total 2,409,000 gallyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs):
Capacity Type Nitrogen Produced per Animal Total
Farrow to Wean
5.4 lbslyr
Ibslyr
600
Farrow to Feeder
6.5 Ibslyr
3,900 Ibslyr
Farrow to Finish
26 lbslyr
Ibslyr
Wean to Feeder
0.48 lbslyr
lbslyr
Feeder to Finish
2.3 lbslyr
lbslyr
Total 3,900 lbslyr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 31.5
Total N Required 1st Year: 8867.5
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops: 8,867.50
Total Nitrogen Produced by Farm: 3,900.00
Nitrogen Balance for Crops: (4,967.50)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2 of 8

Reception Area.:
Tract Fisid Irrigated Soil Ist Crop Time to 1stCrop 1stCrop LbsNtAc
Acreage Type Code Apply Yield lbs N/Unit Residual fAc WIN
���®�r:�a�■�®�®�o���■■moo®�
Oman
����n�ra�■�■s�®�v
=
om�m�®
3(a) of 8

Reception Area Specifications
.. Time to lstCrop LbsNIAC Lbs N Total lbs N
3(b( of 8

This plan does not include commercial fertilizer: The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
1n interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a .
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definatety interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code Crop
A Barley
B Hybrid Bermudagrass - Grazed
C Hybrid Bermudagrass - Hay
D Corn - Grain
E Corn - Silage
F Cotton
G Fescuo - Grazed
H Fescue- Hay
I Oats
J Rye
K Small Grain - Grazed
L Small Grain - Hay
M Grain Sorghum
N Wheat
O Soybean
P Pine Trees
Lbs N utilized 1 unit yield
1.6 lbs N / bushel
50 lbs N 1 ton
50 lbs N 1 ton
1.25 lbs N 1 bushel
12 lbs N 1 ton
0.12 lbs N 1 lbs lint
50 lbs N 1 ton
50 lbs N 1 ton
1.3 lbs N 1 bushel
2.4 lbs N 1 bushel
50 lbs N 1 acre
50 lbs N 1 acre
2.5 lbs N I cwt
2.4 lbs N / bushel
4.0 lbs N 1 bushel
40 lbs N 1 acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PANT rlanimal Farm Totaf r
Farrow to Wean 0.84
600 Farrow to Feeder 1 600
Farrow to Finish 4.1
Wean to Feeder 0.072
Feeder to Finish 0.36
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 600 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 3000 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid Bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 10 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 24 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
`This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
z
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of.once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5of8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract
Hydrant
Type
Crop
inlhr
* inches
T71951
1
FoA
C
0.5
1
T71940
1
Ra
H
0.4
1
T71940
2
Ra
C
0.4
1
`* Optional*
T71951
sub 1
FoA
C
0.5
1
T71940
sub 1
Ra
H
0.4
1
T71940
sub 2
Ra
C
0.4
1
6of8

Additional Comments:
This plan is a revision of the previous plan dated 2002 and an aerway
amendment dated 2003, changing the Bermuda and fescue crops from
gaze to hay.
Acres listed for fields M 2 are 'wetted' acres. Acres listed as sub fields are
the additional aerway acres.
7 of 8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: Genesis Farm
Owner: Dontor Inc. 31-378
Manager:
OwnerlManager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
Ilwe understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner:
Signature:
Dontor Inc. 31-378
Name of Manager (if different from owner):
Signature:
Name of Technical Specialist: Toni W. King
Affiliation: Murphy -Brown, LLC.
Address: 2822 Hwy 24 West, PO Drawer 856
Warsaw, NC 28398
Telephone: [phone]
Signature:
Date
Date
\/� -?i' - -�� 0 -Z�6
Date
8of8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application_ It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recievinq crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2of3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate: Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3of3

Waste Management Plan Changes ECEYVED
�'
]ApR 22 coos
Facility ��5�31� Fan C��neS t S
This farms Waste Management Plan has made the following changes:
❑ Crop changes
❑ Wetted Acres
❑ Increased Acreage
❑ Decreased Acreage
❑ Changed Irrigation Design
❑ Change in Farm type
❑ Plan based on 3 Years On Farm Records
❑ Other
Comments:
rAO
C-,�O 1 Dt
Date

Murphy -Brown, LLC 3/20/2006 2822 Hwy 24 West
P.O. Box 856
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Grower(s):
Farm Name:
Farm
Dontor Inc. 31-378
Genesis Farm
LP11110a
Farrow to Wean
Farrow to Feeder 600
Farrow to Finish
Wean to Feeder
Feeder to Finish
storage structure:
Storage Period:
Application Method:
HnaeroDIc Lagoon
>180 days
Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H _0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft3, tons, etc.):
Capacity Type Waste Produced r Animal Total
Farrow to Wean
3212 galyr
gallyr
600
Farrow to Feeder
4015 gallyr
2,409,000 gal/yr
Farrow to Finish
10585 gallyr
gavyr
Wean to Feeder
223 gallyr
galyr
Feeder to Finish
986 gallyr
galyr
Total 2,409,000 gallyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs):
Capacity Type Nitrogen Produced per Animal Total
Farrow to Wean
5.4 lbs/yr
lbs/yr
600
Farrow to Feeder
6.5 lbs/yr
3,900 lbs/yr
Farrow to Finish
26 Ibslyr
lbs/yr
Wean to Feeder
0.48 lbs/yr
lbs/yr
Feeder to Finish
2.3 Ibslyr
Ibslyr
Total 3,900 lbs/yr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 31.5
Total N Required 1st Year: 8867.5
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops: 8,867.50
Total Nitrogen Produced by Farm: 3,900.00
Nitrogen Balance for Crops: (4,967.50)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2of8

Reception Area Specifications
F-Tract Field Irrigated Sol] 1st Crop Time to IstCrop istCrop LbsNiAc Lbs N Tots I ft N
AcreaRe -Type— Code ABEIZ Yield We N/Unit Residual .-/Ac Utilized
3(b) of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized / unit yield
A
Barley
1.6 lbs N 1 bushel
B
Hybrid Bermudagrass - Grazed
50 lbs N I ton
C
Hybrid Bermudagrass - Hay
50 lbs N I ton
D
Corn - Grain
1.25 lbs N 1 bushel
E
Corn - Silage
12 lbs N / ton
F
Cotton
0.12 lbs N / lbs lint
G
Fescue- Grazed
50 lbs N I ton
H
Fescue- Hay
50 lbs N 1 ton
. Oats
1.3 lbs N / bushel
J
Rye
2.4 lbs N 1 bushel
K
Small Grain - Grazed
50 lbs N / acre
L
Small Grain - Hay
50 lbs N / acre
M
Grain Sorghum
2.5 lbs N / cwt
N
Wheat
2.4 lbs N / bushel
O
Soybean
4.0 lbs N / bushel
P
Pine Trees
40 lbs N 1 acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PAN/yr/animal Farm Total r
Farrow to Wean 0.84
600 Farrow to Feeder 1 600
Farrow to Finish 4.1
Wean to Feeder 0.072
Feeder to Finish 0.36
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 600 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 3000 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 10 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 24 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to property
irrigate the acres shown in the preceding table. ' Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
*This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5of8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract
Hydrant
Tie
Crop
inlhr
^
* inches _
T71951
1
FoA
C
0.5
1
T71940
1
Ra
H
0.4
1
T71940
2
Ra
C
0.4
1
" Optional"
T71951
sub 1
FoA
C
0.5
1
T71940
sub 1
Ra
H
0.4
1
T71940
sub 2
Ra
C
0.4
1
6of8

Additional Comments:
This plan is a revision of the previous plan dated 2002 and an aerwa
amendment dated 2003, chafing the bermuda and fescue crops from
gaze to hay.
Acres listed for fields 1,1 2 are 'wetted' acres. Acres listed as sub fields are
the additional aerway acres.
7of8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: Genesis Farm
Owner: Dontor Inc. 31-378
Manager:
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Dontor Inc. 31-378
Signature: 3"O&
Date
Name of Manager (if different from owner):
Signature:
Name of Technical Specialist: Toni W. King
Affiliation: Murphy -Brown, LLC.
Address: 2822 Hwy 24 West, PO Drawer 856
Warsaw, NC 28398
Telephone: [phone]
Signature:
Date
3--A02�6
0!, Date
8of8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recievinq crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
8 Animal waste shall not be applied to saturated -soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a. manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Wastelnutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or Wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3 of 3

O� WA�F9 Michael F. Easley, Governor
� Q William G. Ross Jr., Secretary
7 North Carolina Department of Environment and Natural Resources
j Alan W. Klimek, P. E., Director
❑ `C
Division of Water Quality
May 1, 2003
Dontor Inc.
Genesis Farm
213 W. Cliff St
Wallace NC 28466
Subject: Certificate of Coverage No. AWS310378
Genesis Farm
Swine Waste Collection, Treatment,
Storage and Application System
Duplin County
Dear Dontor Inc.:
On -April 28, 2003, the North Carolina General Assembly ratified Senate Bill 733 which directs the
Division of Water Quality (Division) to extend the expiration date of the Swine Waste Operation General
Permit AWG100000. Therefore, the General Permit has been re -issued by the Division to extend the
expiration date to October 1, 2004. During the period of this extension the Division will be working with
all interested parties on the development of a new version of the Non -Discharge General Permit.
In accordance with your application received on February 27, 2003 and in accordance with the directive
of Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to Dontor
Inc., authorizing the operation of the subject animal waste collection, treatment, storage and land
application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AWS310378 which expired on April 30, 2003.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from -the Genesis Farm, located in Duplin County, with an animal capacity of no greater
than an annual average of 600 Farrow to Feeder swine and the application to land as specified in the
facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or Farrow to
Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary, they may
be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a rate of 4
gilts for every 3 sows
The COC shall be effective from the date of issuance until October 1, 2004- Pursuant to this COC, you
are.authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC-(as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property. A�aarr
��
RIENOR
Non -Discharge Permitting Unit
1617 Mail Service Center, Raleigh, NC 276W1617
Customer Service Center
An Equal Opportunity Action Employer
Internet http://h2o.enr.state.nc.us/ndpu
Telephone [phone] Fax [phone]
Telephone [phone]
50% recycled/10% post -consumer paper

Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per NRCS standards a 100 foot separation shall be maintained between water supply wells and any
lagoon or any wetted area of a spray -field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWNlP may result in the revocation of this COC, or penalties in accordance with NCGS .143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A namelownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Wilmington Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Sue Homewood at [phone] ext. 502..
Sincerely,
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
CC' (Certificate of Coverage only for all cc's)
Wilmington Regional Office, Water Quality Section
Duplin County Health Department
Duplin County Soil and Water Conservation District
Permit File AWS310378
NDPU Files

Mutphy-Brownuc PO Drawer 856
2822 Hwy. 24 West
Warsaw, NC 28398
Tel: [phone]
Fag: 910-293-6957
January 6, 2003
Kim H. Colson, P. E.
North Carolina Division of Water Quality
Water Quality Section
Non -Discharge Permitting Unit
1617 Marl Service Center
Raleigh, NC 27699-1617
Mr. Colson,
Enclosed you will find a completed NPDES Short Form B — Existing Facility for
(Farm Name), Facility # (number) in (county). In addition, I have included a copy of the
most recent Waste Utilization Plan as requested. By way of this letter, I am requesting
that the permitted capacity for this facility reflect that no boars are currently being used
on this facility. It is my understanding that the design criteria used as the basis of the
certification and original permitting of this facility accounted for 1 boar space per 15
sows in the steady state live weight calculations. I would ask that the new permit reflect
an animal population of (current # of permitted sows x 1.067). A change in the CAWMP
should not be required because the type of facility and number of animals present on the
farm will be the same.
If further information is needed, or if you have any questions or concerns
regarding this letter, the enclosed application, or Waste Utilization Plan, please feel free
to contact me at (phone number).
Sin
(Name and Title)
Enc.

Murphy-Brommuc PODraver856
2822 Hwy. 24 West
Warsaw, NC28398
Tel: [phone]
Fag: 910-293-6957
January 6, 2003
Kim H. Colson, P.E.
North Carolina Division of Water Quality
Water Quality Section
Non -Discharge Permitting Unit
1617 Mail Service Center
Raleigh, NC 27699-1617
Mr. Colson,
Enclosed you will find a completed NPDES Short Form B — Existing Facility for
(Farm Name), Facility # (number) in (county). In addition, I have included a copy of the
most recent Waste Utilization Plan as requested. By way of this letter, I am requesting
that the permitted capacity for this facility reflect that no boars are currently being used
on this facility. It is my understanding that the design criteria used as the basis of the
certification and original permitting of this facility accounted for 1 boar space per 15
sows in the steady state live weight calculations. I would ask that the new permit reflect
an animal population of (current # of permitted sows x 1.067). A change in the CAWMP
should not be required because the type of facility and number of animals present on the
farm will be the same.
If further information is needed, or if you have any questions or concerns
regarding this letter, the enclosed application, or Waste Utilization Plan, please feel free
to contact me at (phone number).
Sincerely —
(Name and Title) -
Enc.

00c
WAST&UTIL17ATION .PLAN=
PRODUCER: Genesis Farm; Dontor Inc.
LOCATION: 368 Eneas Lanier Rd
Chinquapin, NC 28521
TELEPHONE: [phone]
TYPE OPERATION: Farrow - Feeder
�r
NUMBER OF ANIMALS: 600
(Design Capacity)
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface and/or groundwater. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops in the fields where the waste is
to be applied. This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle. Annual soil tests are strongly encouraged so that all
plant nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and available water holding capacities. Normally waste shall not be applied to land
eroding at greater than 5 tons per acre per year. With special precautions, waste may be
applied to land eroding at up to 10 tons per year. Do not apply waste on saturated soils, when it
is raining, or when the surface is frozen. Either of these conditions may result in runoff to
surface waters which is not allowed under DEM regulations. Wind conditions should also be
considered to avoid drift and downwind odor problems. To maximize the value of nutrients for
crop production and to reduce the potential for pollution, the waste should be applied to a
growing crop or applied to bare ground not more than 30 days prior to planting. Injecting the
waste or disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for analysis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H.0217 adopted by the Environmental Management Commission.
Page 1

:WASTE. UTILIZATION, PLAN.
Amount of Waste Produced Per Year(gallons, fttons etc.
600 animals X 3861 (gal) wastelanimallyear = 2,316,600 (gal) waste/year.
Amount of Plant Available Nitrogen (PAN) Produced Per Year
600 animals X 6.5 lbs. PAN/animal/year = 3,900 lbs. PAN/year. (PAN from N.C.
Guide Std. 633) Tech
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner
The following acreage will be needed for waste application based on the crop to be grown and surface
application:
Table 1: ACRES OWNED BY PRODUCER
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
# No. Type Per Acre Utilized Application
71951
1
FoA
Bermuda G
255
4.08
1040.4
March - Sept
71940
1
Ra
Fescue G
190
3.92
744.8
Feb-JunelS-Nov
71940
2
Ra
Bermuda G
190
8.97
1704.3
March - Sept
—1 &-2
Small Grain
50
13.05
652.5
Sept - April
0
0
0
0
0
0
0
0
Total 1 16.971 4,142.00
*This N is from animal waste only. if nutrients from other sources such as commercial fertilizer are
applied, they must be accounted for. N must be based on realistic yield expectation.
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N requirements.
Beginning in 1996 the Coastal Zone Management Act will require farmers in some eastern counties of
North Caroline to have a nutrient management plan that addresses all nutrients. This plan only
addresses Nitrogen.
Page 2

WASTE UTILIZATION PLAN
Table 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowner must be attached)
(Required only if operator does not own adequate land [see
Required Specification 2])
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
* See footnote for Table 1.
Totals from above Tables
Acres Lbs. N
Utilized
Table 1 16.97 4,142
Table 2 0.00 -
Total 16.97 4,142
Amount of N Produced 3,900
Surplus or Deficit 242
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to prevent over
application of nutrient or other elements.
Page 3

'E�WASTEFUTIL'IZATIQN-PLAN � ��- - ��� e s`
See attached map showing the fields to be used for the utilization of waste water.
Application of Waste by Irrigation
Field Soil Type Crop Application Application
Nn Rate fInlHrl Amount (in.)
1
FoA
Bermuda
0.5
0.5
1 &2
Ra
Pasture
0.4
0.5
THIS TABLE IS NOT NEEDED IF WASTE IS NOT BEING APPLIED BY IRRIGATION, HOWEVER A SIMILAR TABLE
WILL BE NEEDED FOR DRY LITTER OR SLURRY.
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 MONTHS. In no instance should the volume of
waste being stored in your structure exceed Elevation' *19" freeboard as per lagoon gauge.
Call the local Natural Resources Conservation Service (formerly Soil Conservation Service) or Soil
and Water Conservation District office after you receive the waste analysis report for assistance in
determining the amount per acre to apply and the proper application rate prior to applying the
waste.
Narrative of operation: The acreage used in this plan is the effecitive "wetted" area from the
irrigation design. Tract 71940 will be in Fescue and the other two tract will be in bermu_dawhich
will be overseeded with small orain in the winter.
Page 4

WASTE UTILIZATION. PLAN„
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of waste, he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner of the facility to
secure an update of the Waste Utilization Plan when there is a change in the operation,
increase in the number of animals, method of utilization, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climatic conditions, and level
of management, unless there are regulations that restrict the rate of application for other
nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but less than 90 tons per acre per
year providing grass filter strips are installed where runoff leaves the field. (See FOTG
Standard 393 - Filter Strip).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6 When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland,
the waste may be broadcast provided the application does not occur during a season
prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order to control odor or flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
Page 5

WASTEUTILIZATION -PLAN,,.,.,-
REQUIRED
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced as necessary to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied pre -plant with no further applications animal waste
during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste analysis records shall be kept
for five years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
a]
Dead animals will be disposed of in a manner that meets North Carolina regulations.
Page 7

W
WASTE � UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: Genesis Farm
Owner/ Manager Agreement
I (we) understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. I (we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new facilities will require a new
certification to be submitted to the Division of Environment Management (DEM) before the
new animals are stocked. I (we) also understand that there must be no discharge of
animal waste from this system to surface waters of the state from a storm event less
severe than the 25-year, 24-hour storm. The approved plan will be filed on -site at the farm
office and at the office of the local Soil and Water Conservation District and will be
available for review by DEM upon request.
Name of Facility Owner: Dontor Inc.
(Please print)
Signature: _ Date: i/ /Z a z
Name of Manager (If different from owner): Jose Luis Torres
Signatur a/%S Date:
Name of Technical Specialist: (Please print) Toni W. King
Affiliation: Murphy - Brown
Address (Agency): P.O. Box 856
Warsaw, NC 28398
Signature: �] Date: IZ_ CZ
Page 8

G'ene� is 30, ay POA 7-21-03.x1s C— r�
Subject: Genesis 30 day POA 7-21-03.xls-
Date: Tue, 22 Jul 2003 15:03:47 -0400
From: "Toni King" <[e-mail]>
Organization: Murphy -Brown LLC
To: "Chester Cobb" <[e-mail]>
Name: Genesis 30 day POA 7-21-03.xls
Type: Microsoft Excel Worksheet
MGenesis 30 day POA 7-21-03.x1s (applicationlvnd.ms-excel)
Encoding: base64
Download Status: Not downloaded with message
1 of 1 7/23/2003 10:29 AM

PLAN OF ACTION(Poa) FOR HIGH FREEBOARD AT ANIMAL FACILITII
Facility Number:
31-378
County: Du lin
Facility Name: Genesis Farm
Certified Operator Name: Rick Donnely Operator Number:
17192
1. Current liquid level(s) in inches as measured from the current liquid level in the lagoon to the
lowest point on the top of the dam for lagoons without spillways; and from the current liquid level
in the lagoon to the bottom of the spillway for lagoons with spillways.
Lagoon NameliD
Spillway(Y or N):
Level(inches):
Lagoon 1 Lagoon 2 Lagoon 3 Lagoon 4 Lagoon 5
31-378
N
12
2. Check all applicable items
Liquid level is within the designed structural freeboard elevations of one or more structures.
Five and 30 day Plans of Action are attached. Hydraulic and agronomic balances are
within acceptable ranges.
X Liquid level is within the 25 year 24 hour storm elevations for one or more structures. A
30 day Plan of Action is attached. Agronomic balance is within acceptable range.
Waste is to be pumped and hauled to off site locations. Bolume and PAN content of waste
to be pumped and hauled is reflected in section III tables. Included within this plan is a list
of the proposed sites with related facility numbers, number of acres and receiving crop
information. Contact and secure approval from the DWQ prior to transfer of waste to a site
not covered in the facility's CAWMP.
Operation will be partially or fully depopulated.
*Attach a complete schedule with corresponding animal units and dates fro depopulation
*if animals are to be moved to another permitted facility, provide facility number, lagoon
freeboard levels and herd population for the receiving facility
3. Earliest possible date to begin land application of waste: 07/21/2003
I hereby certify that I have reviewed the information listed above and included within the
attached Plan of Action, and to the best of my knowledge and ability, the information is
accurate and correct.
Rick Donnelly Phone:
Facility Owner/Manager (print)
Date:
Facility Owner/M ger (signature)
910-285-4234
07121 /2003

II. TOTAL POUNDS OF PAN STORED WITHIN STRUCTURAL FREEBOARD AND/OR 25 YR.124
HR. STORM STORAGE ELEVATIONS IN ALL WASTE STRUCTURES FOR FACILITY
1.
Structure ID: 31-378
line m =
909.6 lb PAN
2.
Structure ID:
line m =
lb PAN
3.
Structure ID:
line m =
lb PAN
4.
Structure ID:
line m =
lb PAN
5.
Structure ID:
line m =
lb PAN
6.
Structure ID:
line m =
lb PAN
n. lines 1 + 2 + 3 + 4 + 5 + 6 = 909.6 lb PAN
III. TOTAL PAN BALANCE REMAINING FOR AVAILABLE CROPS DURING 30 DAY DRAW DOWN
PERIOD_ DO NOT LIST FIELDS TO WHICH PAN CANNOT RE APPLIED DURING THIS 30 DAY PERIOD_
o. tract #/
p. field #
q. crop
r. acres
s. remaining 1RR
2 PAN balance
(Iblacre)
t. TOTAL PAN
BALANCE FOR
FIELD (lbs.)
column r x s
U. application window'
T71951
1
Bermuda G
1.06
242.00
256.5
March - Sept
T71951
2
Bermuda G
3.02
175.00
528.5
March - Sept
T71951
4
Bermuda G
2.34
160.00
374.4
March - Sept
'State current crop ending application date or next crop application beginning date for available
receiving crops during 30 day draw down period.
v. Total PAN available for all fields (sum of column t) = 1159.4 lb. PAN
IV. FACILITY'S PoA OVERALL, PAN BALANCE
PoA (30 Day) 2121100

w. Total PAN to be land applied (line n from section il) = 909.6 lb. PAN
x. Crop's remaining PAN balance (line v from section III) = 1159.4 lb. PAN
y. Overall PAN balance (w - x) _ -250 lb. PAN
Line y must show as a deficit. If line y does not show as a deficit, list course of action here including pump and
haul, depopulation, herd reduction, etc. For pump & haul and herd reduction options, recalculate new PAN
based on new information. If new fields are to be included as an option for lowering lagoon level, add these
fields to the PAN balance table and recalculate the overall PAN balance. If animal waste is to be hauled to
another permitted facility, provide information regarding the herd population and lagoon freeboard levels at the
Irrigation onto existing spray fields will continue as weather and field conditions permit. Additional land is
available for pumping if needed.
PoA (30 Day) 2/21100

It
PLAN OF ACTION (POA) FOR HIGH FREEBOARD AT ANIMAL FACILITIES
30 DAY DRAW DOWN PERIOD
I. TOTAL PAN TO BE LAND APPLIED PER WASTE STRUCTURE
1. Structure Name/Identifier (0): 31-378
2. Current liquid volume in 25 yr./24 hr. storm storage & structural freeboard
a. current liquid level according to marker 12.0 inches
b. designed 25 yr./24 hr. storm & structural freeboard 19.0 inches
c. line b - line a (inches in red zone) = 7.0 inches
d. top of dike surface area according to design
(area at below structural freeboard elevation) 54696 Ift2
e. line 02 x line d x 7.48 gallons/W 238657 gallons
3. Projected volume of waste liquid produced during draw down period
f. temporary storage period according to structural design 180 days
g. volume of waste produced according to structural design 263088 ft3
h. current herd # 600 certified herd # 600
actual waste produced = current herd # x line g =
certified herd #
i. volume of wash water according to structural design
j. excess rainfall over evaporation according to design
k. (lines h + i + j) x 7.48 x 30 days/line f=
4. Total PAN to be land applied during draw down period
I. current waste analysis dated 1 06/10/2003
m. ((lines e + k)/1000) x line I =
REPEAT SECTION I FOR EACH WASTE STRUCTURE ON SITE.
(Click on the next Structure tab shown below)
263088 ft'
0 ft3
31906 W
367759 gallons
1.50 Ibs/1000 gal.
909.6 lbs. PAN
PoA (30 Day) 2/21/00

• Mar 24 03 04:23p MURPHY-BROWN 910293313E P-1
t
Murphy -Brown LLC -
TO:
FROM:
1
DATE:
PAGES:
t
CONVMNTS:
FAX TRANSMISSION
C',
PO Drawer 856
'822 Hwy. 24 West
Warsaw, NC 29398
Td: 910-293-5334
F= 910-293-3138
.T

Mar 24 03 04:23p MURPHY-BROWN 9102933138 p.2
MAR-24-03 83:20 PM GENESIS FARM 910 283 4399 P.01
,,Or eq uj U4:00P MURPHY-BROWN
81 fl2833138 P. 2
PLAN OF ACTtON(Poa) FOR HIGH FREEBOARD AT ANIMAL FACILITIES
F,661ly Nurn:rw: 3"79 Coun:y: Ih sib
Facility Name Genesis Farm
Ce►tr,ed Operator Nei -is; Rick Dqnnoly Operator Nvrrttw'
1. Cunenl listuid irve (a) in inchc3 " nVowirec front the c;umw.t lkuid !e el in Cho tagoan to the
nrxdsl punt cai the to . of 11110 Cam for laguara wintoat 3041 ray*: and fro'1 the current llgtlid Keel
in :he lanncn to the aottan of the spillway fer tagoorw witn spilwa fs.
Ladoori 1 Lagmzr•. 2 Lagoon 3 L8goor.4 Ira"W 5
Lopm Na•re)`10' 31 37a
SPA .VY6�y or Nt= N
16
2 Chc-tk tlli a;_VLc We itern3
- Liquid ievM is within the desigried otruottool f aoboard eisvatia o% of or more struct►aes.
F tic 8no .10 day Ptans of Act art arw auacl, vf�tkau is and agronomic balances are
will -in Zecapt8hte, ranges.
X _ ' .q;sld wroj i* within tho 26 ye3r 24 ho.ir smrrn eleva:ims fo• one or RVA0 cKu: WOS . A
—Xi cmy f•Inn or Action is 0ltadwd. Agraficmic bdiortce iu within aCCeotaWn r,wig t,
is to 5e pumped and hauled to off sate kwatio-o. eohrme av PAN content nt waste
to ,te pumped and hau ed is reflected in section III tab es. InCRldad with-n" plin is C lis,
of the Proposed s:tr=s with related faciflty rwmbem, '>Ltt"r of was and rece;vtiq c-op
nrhxmation. Coritect and secure ap{rmval front the DWO pnor to transforaf -miste to a sUe
out covored in the facky's CAM01P.
— -• - _-- Mperatinr *ii bo o;; t lfy or turfy depcpulateC
Wv3cir a mrnpiele schedule w.th couerrlrwwing ani :.as -ran sane dates fro depopulatiur.
'i' animals are 'D be mv,•Gd to another pccmilMd facility, provide facihly number, Isga-3n
t'oebo3rd 4"13 and hgrd populalm nor Me r"—,v-.rt1; f8t lity
3 E • basi possib.o date to begin land aopiic abon of waste:
I hereby certify that I have reviewed the tnfan+nation fisted above and in:itrdod within the
attarbed Plan of Action, and to the beat of my knowledge a* abllfty, the information i3
aoca,rate and correct. �t
C-L �1 0f\ Phone:
F:loitity o nRr!wit t tanager (p+
j� ""-
FacMty ovrt (sig•t aws)

Mar 24 03 04:23p MURPHY-BROWM 9102933138 p.3
It. TOTAL POUNDS OF PAN STORED WITHIN STRUCTURAL FREEBOARD ANDIOR 25 YR.124
HR. STORM STORAGE ELEVATIONS IN ALL WASTE STRUCTURES FOR FACILITY
1. Structure ID: 31-378
line m =
584.5 lb PAN
2. Structure ID:
line m =
-lb PAN
3. Structure ID:
line m =
lb PAN
4. Structure ID:
line m =
lb PAN
5. Structure ID:
line m =
lb PAN
6. Structure ID:
line m =
lb PAN
n. lines + 2 + 3 + 4 + 5 + 6 = 584.5lbPAN
III, TOTAL PAN BALANCE REMAINING FOR AVAILABLE CROPS DURING 30 DAY DRAW DOWN
PERIOD. DO NOT LIST FIELDS TO WHICH PAN CANNOT BE APPLIED DURING THIS 30 DAY PERIOD_
..BALANCE
-
FOR
-
.columnrxs
'State current crop ending application date or next crop application beginning date for available
receiving crops during 30 day draw down period.
v. Total PAN available for all fields (sum of column t) = 1 D40.4 lb. PAN
IV_ FACILITY'S PoA OVERALL PAN BALANCE
PoA (30 Day) 2121 /00

Mar 24 03 04:23p MURPHY-BROWM 9102933138 p.4
w. Total PAN to be land applied (fine n from section 11) = 584.5 lb. PAN
x Crop's remaining PAN valance (line v from section 111) = 1040.4 lb. PAN
y. Overall PAN balance (w - x) = -456 lb. PAN
Line y must show as a deficit. If line y does not show as a deficit, list course of action here including pump and
haul, depopulation, herd reduction, etc. For pump & haul and herd reduction options, recalculate new PAN
based on new information. If new fields are to be included as an option for lowering lagoon level, add these
fields to the PAN balance table and recalculate the overall PAN balance. If animal waste is to be hauled to
another permitted facility, provide information regarding the herd population and lagoon freeboard levels at the
gation onto existing spray fields will continue as weather and field conditions permit. Additional land is
ailable for pumping if needed.
PoA (30 Day) 2121/00

r
Mar 24 03 04:24p MURPHY-BROWN
9102933138
p.5
PLAN OF ACTION (PoA) FOR HIGH FREEBOARD AT ANIMAL FACILITIES
30 DAY DRAW DOWN PERIOD
I. TOTAL PAN TO BE LAND APPLIED PER WASTE STRUCTURE
1. Structure Namelidentifier (ID): 31-378
2. Current liquid volume in 25 yr.124 hr. storm storage & structural freeboard
a_ current liquid level according to marker
16.0 inches
b. designed 25 yrJ24 hr. storm & structural freeboard
19.5 inches
c. line b - line a (inches in red zone) =
3.5 inches
d. top of dike surface area according to design
(area at below structural freeboard elevation)
54696 fe
e. line d12 x line d x 7.48 gallonslft'
119328 gallons
3. Projected volume of waste liquid produced during draw down period
E temporary storage period according to structural design 1$0 days
g. volume of waste produced according to structural design 263088 ft3
h. current herd # 600 certified herd #1 600
actual waste produced = current herd # x line g = 263088 fe
certified herd #
i. volume of wash water according to structural design
j. excess rainfall over evaporation according to design
k. (lines h + i + j) x 7.48 x 30 daystline f=
4. Total PAN to be land applied during draw down period
I. current waste analysis dated I D3/0112003
m. ((lines e + ku1000) x line I =
REPEAT SECTION I FOR EACH WASTE STRUCTURE ON SITE.
(Click on the next Structure tab shown below)
PoA (30 Day) 2121/00
®fi3
31906 fe
367759 gallons
1.20 lbs/1000 gal.
584.5 lbs. PAN

s
0 warFROG Michael F_ Easley, Governor
r� William G. Ross Jr., Secretary
rl North Carolina Department of Environment and Natural Resources
i f Alan W. Klimek, P-E., Director
p � TQ
SEpt
26 2002 � � Division of Water Quality
�11 "
September 26, 2002
Dontor Inc.
Genesis Farm
368 Eneas Lanier Road
Chinquapin NC 28521
Attn: Jose L. Torres
Subject: Certificate of Coverage No. AWS310378
Genesis Farm
Swine Waste Collection, Treatment,
Storage and Application System
Duplin County
Dear Mr. Torres:
In accordance with your Notification of Change of Ownership request received on September 19, 2002,
we are forwarding this Certificate of Coverage (COC) issued to Dontor Inc., authorizing the operation
of the subject animal waste collection, treatment, storage and land application system in accordance with
General Permit AWG100000. This approval shall consist of the operation of this system including, but
not limited to, the management of animal waste from the Genesis Farm, located in Duplin County, with
an animal capacity of no greater than 600 Farrow to Feeder and the application to land as specified in
the Certified Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003 and shall hereby void COC
Number AWS310378 dated March 11, 1999. Pursuant to this COC, you are authorized and required to
operate the system in conformity with the conditions and limitations as specified in the General Permit,
the facility's CAWMP, and this COC, with no discharge of wastes to surface waters. An adequate
system for collecting and maintaining the required monitoring data and operational information must be
established for this farm. Any increase in waste production greater than the certified design capacity or
increase in number of stocked animals above the number authorized by this COC will require a
modification to the CAWMP and this COC and shall be completed prior to actual increase in either
wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This request
shall be made within 30 days of notification by the Division.
*w
Non -Discharge Permitting Unit Intemet http91h2o.enr.ne.state.uslndpu NMENR
1617 Mail Service Center, Raleigh, NC 27699-1617 Telephone [phone] Fax [phone]
DENR Customer Service Center Telephone [phone]
An Equal opportunity Action Employer 50% recycled110% post -consumer paper

• ,4 '
This COC is not automatically transferable. A name/ownership change application must be submitted to
the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual non -discharge permit by contacting the engineer listed below for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding_
The subject farm is located in the Wilmington Regional Office. The Regional Office Water Quality Staff
may be reached at [phone]. If you need additional information concerning this COC or the
General Permit, please contact Michelle Barnett [phone] ext. 544.
Sincerely,
Alan W. Klimek, P.E.
cc: (Certificate of Coverage only for all cc's)
Duplin County Health Department
WilmingtpmRegional-Office,-Water Quality-Sec`tion .
Duplin County Soil and Water Conservation District
Water Quality Central Files
NDPU Files
r

09/19/2002 14:19 FAX [phone] HLTMAN RESOURCES ID002
1
• ,� Notification of Change of Ownership
Animal Waste Management Facility
(Please type or print all Information that does not require a signature)
In accordance with the requirements of 15A NCAC 2H .0217(a)(1)(H)(xii) this form is official notification to the Division of i
Water Quality (DWQ) of the transfer of ownership of an Animal Waste Management Facility- This form must be f
submitted to DEM no later than 60 days following the transfer of ownership.
General Information:
Name of Farm: Genesis Farm Facility No: 31-378 l t
Previous Owner(s) Name: Rocky Mobley Phone NO: 910.285-4599 !
's
New Owner(s) Name: Dontor Inc. _ Phone No: 910-285-4234
Mailing Address: 368 Eneas Lanier Rd. ChinquapLn, NC 28521
Farm Location: Fourteen Digit Hydroligic Unit
Latitude and Longitude: 34 49' 19` 1 77 43' 55" County: Duplin
Please attach s copy of a county road map with location identified and described below (Be -specific:. road _
names, directions, milepost, etc.): - From Chinquapin take NC 41 Borth toward Sealuaville about .8 mile out of town;
bear right on NC 111 South For .5 mile, turn right on SR 1817; go 3.5 miles to farm entrance on the right.
i
Operation Description:
Type of swim No. of Animals Type cr Poultry No. of Animals Type of Cattle No. of Animals i
s
0 wean to Feader Layer 0 Dairy
0 Feeder to Finish Pullets 0 Beef i
Farrow to wean
I� Farrow io Feeder 600
0 Farrow to Finish
E] Gilts
soars - -
Acreage Available far Application; 16.97 Required Acreage: 15.96 t
Number of Lagoons I Storage Ponds: 1 Total Capacity: 430,944 Cubic Feet (ft3)
�e.isi�tfre**tsr�:rr�esv�*w+�orWwkr►del+r+rtfnrtxefexwtifftts:fZ=��r�sar*iiWV4�iJri*iitlt4z:rrrrrms�re�r�r►iWMWM iYriYiyr.LW.Nnew*.rww..rwfrw►kfnrw r
Owner I Manager Agreement
I (we) verify mat all the above information is correct and will be updated upon changing. I (we) understand the operation and malntenance prooedures
— ns iiiishzd in the approved dnirnal waste management plan for the farm named above and will implement VIese procedures. I (we) know that any
expansion to the exlsling design capacity of the w asm treatment and storage sysiern or construction of new FacTi tes will require a new certification to be
submitted to the Division of Environmental Management before the new animals are stocked. I (we) understand that there must be no discharge of
animal waste from the storage or application system to surface waters of the siate either directly through a man-made conveyance a from a storm
event less severe than the 25 -year, 24 - hour storm and there must not be run-off from the application of animal waste. l (we) understand that run-off
of pollutants from lounging and heavy use areas mist be minimized using technical standards developed by the Natural Resources Conservation i
Service. The approved plan will be filed at the farm and at the office of the local soil and Water Conservation DistricL I (we) know that any modification
roust be approved by a technical specialist and submitted to the Soil and Water Conservation District prior to implementation. A change in land
ownership requires written notification to DEM Or a new certification CHI the approved plan is changed) within 60 days of a title transfer. 4
s
Name of New Land Owner: Dontor, Inc.
SlgnaturejL Date: r, T// f A 7—
Name of Manager (if di from owner): Jose Torres ;
Signature 1j2 Date
Please sign and return this form to: N.C. Division of Water Quality
Water Quality section, Compliance Group '
Raleigh, NC 27626-0535 s
NCO -1 Ma<; 3, 1996 -
,Jose- ' L.

Environmental Chemists, Inc.
P.O. Box 1037
® Wrightgville Bench, NC 28480
i
MAR 2 4 NOD
C

Environmental Chemists, Inc.
® 6602 Windmill Way • Wilmington, North Carolina 28405
[phone] (Lab) • [phone] (Fax)
EchemW @aol.com
CONSULTING
CHEMISTS NCDENR: DWQ CERTIFICATE #94, DLS CERTIFICATE #37729
Customer: .
NCDENR-DWQ
127 N. Cardinal Drive Ext.
Wilmington, NC 28405
Attn: Stonewall Mathis
Date Sampled:
Sampled By:
STREAM:
03/09/00
Stonewall Mathis
REPORT OF ANALYSIS
Date of Report: March 22, 2000
Purchase Order #:
Report Number: 0-0769
Report To: Stonewall Mathis
PARAMETER
Sample ID
RM Up
RM Down
RMC
Lab ID
# 1978
# 1979
#1980
Fecal Coliform, colonies/100ml
450
144
18
Nitrate + Nitrite Nitrogen, NO3 + NO2 - N mg/L
0.59
1.86
0.23
Ammonia Nitrogen, NH3-N, mg/L
0.1
0.2
0.6
Total Kejeldahl Nitrogen, TKN mg/L
1.5
1.7
1.7
Total Phosphorus, P mg/L
0.47
0.53
0.09
Reviewed b ( and approved for release to the client.

ENVIRONMENTAL CHEMISTS, INC
Sample Collection and Chain of Custody
Client:
Collected By: ,54o h c w0 1
Qamnlp Tvnp- I = Inflnpnt_ F Ffflnpnt_ W =Wp11_ =Ctrpsm fin =,Rail_ R1 = kii dop nthpr!
6602 Windmill way
Wilmington, NC 28405
Phone: [phone]
Fax: [phone]
Sample Identification
Collection
F
e
U
o
V
w
PRESERVATION
ANALYSIS REQUESTED
z
W
-
c
C
DATE
TIME
TEMP
19- 8sa
6-4l
G
c
A
c'Al
G
-DawlJ
C
G
� �
A
o
fV1 G
I
G
G
C
P
G
G
C
P
G
G
C
P
G
G
C
P
G
G
NOTICE — DECHLORINATION : Samples for Ammonia, TKN, Cyanide, Phenol, and Bacteria must be dechlorinated
0.2 ppm or less in the field at the time of collection. See reverse side for instructions.
Transfer
Relinquished By:
Date/Time
Received By:
Date/Time
1.
2.
Temperature when Received: !. ' C- Accepted: V cted: Resample Requested:
Delivered By: a Received Date: --slolco Time:+'i0orn
Comments:
1

nn
IMPORTANT NOTICE
IF
North Carolina Division of Water Quality (DWQ) is strictly enforcing EPA regulations for sample collection
and preservation.
Client Must Provide the Following Information
1. SAMPLE IDENTIFICATION (Container Associated with requested testing)
2. SAMPLE TYPE (Composite, Crab, Water, ,Soil, etc.)
3. DATE COLLECTED
4. TIME_ COLLECTED
5. SAMPLE COLLECTOR
6. PRE(Including Temperature and pH )
Temperature _Samples MUST be refrigerated or received on ice between
2 and 6° C. Samples received within two (2) hours of collection must show a downward trend.
Therefore, please record temperature at.collection: in space provided on collection sheet.
gH : _A two (2) hour limit to chemically preserve samples by pH adjustment is allowed, except for
metals samples reported to the Groundwater Section which must be acidified at the time of collection,
DECHLORINATION INSTRUCTIONS
CAUTION: DO NOT Mix thiosulfate with acid in bottle before collecting sample as a
violent reaction will occur.
Dechlorinating Sam les that Require Acid Preservation
1, Add 4-5 granules of thioselfate to a bottle with no acid preservative
( uupreserved BOD/TSS bottle).
2. After mi dug to disslove the thiosulfate, pour half of the sample into a battle captaining acid as a
preservative (Amuaonia/TM
3. Then completely fill both bottles with f mb sample.
The Laboratory will verify and domment the above requested information.
re_f: NCAC 2H.0805 (a) (7) M
" At anytime a laboratory.receives samples which do not meet sample collection, holding tune, or preservation
requirements, the laboratory must notify the sample collector or client and secure another sample if possible. If
another sample cannot be secured, the original sample may be analyzed, but the results reported must be
qualified with the nature of the infiaction(s). And the laboratory must notify the State Laboratory about the
in raacticm(s). The ratification must include a statement indicating corrective actions taken to prevent the
problem for fixture samples.
ref._ NCAC 2H.0805 tam. "

r�h23--00 01 : 45P Env i vochom 910 392 4424 P . 01
Environmental Chemists, Inc.
6602 Windmill Way 910392.0223 phone
Wilmington, 910-392.4424 fax
CONSULTING CHEMISTS North Carolina 28405 EchemW(a�aol,com
facsimile transmiffal'496000090*000 *see
To: ft Al From:
Company: -1 .ice Date: _`'��Z3�cx�) - - -- Fax No.:Pages to
Re: �� C' ► ! - Follow:
Messa e:
STREAM:
PARAMETER
Sample ID
RM i3p
RM Down
RMC
Lab ID
# 1978
# 1979
#1990
Fecal CoUform, colon its/ I00ml
450
144
18
Nitrate + Nitrite Nitrogen, NO3 + NO2 - N mg/L
0.59
1.86
0.23
Ammonia Nitrogen, NHj-N, mg/L
0.1
0.2
0.6
Total Kejeldahl Nitrogen, TKN mg/L
1.5
1.7
1.7
Total Phosphorus, P mg/L
0.47
0.53
0.09
Reviewed by', 7�L: y,: 1 �,Ci��t C and approved for release to the client.

a ENVIRONMENTAL CHEMISTS, INC
0
LL7�� a Sample Collection and Chain of Custody,
Client: AJG DE- rj A - aW Q
Collected By; .�4areLlr! j 1�+�G �,-5 _ --� �
Q.......t.. Tamar 7 = 7..ff..e..t F = F.ff llmni W —WP11 � Ctrowrn Q0 GCnil_ Ci = Cludaa (lthar-
6602 Windmill Way
Wilmington, NC 28405
Phone: [phone]
Fat. [phone]
Sample Identification
Collection
S
a
v
o
8
a
PRESERVATION
ANALYSIS REQUESTED
x
x
DATE
TIME
TEMP
19-1$A
'7�
G
TAM P 0vi Aj
-
C
A
�e c',
G
G
C
w
✓
�c��
%�M�
I g
IJU4���5
G
G
C
P
G
G
C
P
G
G
C
P
G
G
C
P
G
G
NOTICE.— DECHLORINATION : Samples for Ammonia, TKN, Cyanide, Phenol, and Bacteria must be dechlorinated
0.2 ppm or less is the field at the time of collection. See reverse side for instructions.
Transfer Relinquished By:
Date/Time
Received By:
Date/Time
1.
2.
Temperature when Received: 1. 14 0 r Accepted: V ' cted: Res&grpie Requested:
Delivered By: '' Received By. { c�n,�C Date: --slq co Time:±F-)1arn
Comments:

P. 1
- C mnnr
---------------
334 MEMORY TX
COMMUNICATION RESULT REPORT ( MAR.15.2M NCDENR WIRO
RESULT PAGE
OPTION --ADDRESS—(GROUP) ------ -- ------ ---
--------- OK
--------------- B-9102652809---------
----REASON FOR ERROR E-2) BUSY
E-1) HANG LP OR LINE FAIL E—q) NO FACSIMILE CONNECTION —
E-3) NO -ANSWER
' . Mate of North Carolina . ; . ...
13epa=Cnt of Environmcmt and Natural Resources -
;-Wilmington Regional Office:-
James 13. Hunt, Gr Vernor BIH Holman, Secretary
FAX COVER SHEET
Date: ZI s_! ao • _ - o. Of Pages:
To: a b�,_ -From: 5�,t:.��a l� err
• 910- 200
-,REMARKS: . Rr'lrsAl KS: G� f• r ,�i�+ l Z�l. �, ., , -... , .. _,
! l
CSUf� tGt�G✓. op rp
127 Cardinal Drive Extension, Wilmington, N,G $S405.3845 Telephone [phone] FAX [phone]
An Equal Opportunity A irmn4ve Attioq Employer `

State of North Carolina
7 Departmentof Environment and NatluaI'Resources -.
Wilmington Regional Office
-r �s�-•r... •x,«�.n---, -'r.� "+r C,c t r ^-ute: •x'. 'x-+=:: ier�-r„e�- ��+�etc-'�,:-i•r:Y�..r: _. �- - ,..x.»�.ai�-r-c•�r s-r+��e7ss
.� .;vT r.. ., •�• _ r ._-.c �.,p� � r-.�fi 1--y - � i. -`�� f.- c _ +c;r+V;r �.� _ sy:.,• 7-.t}x
--'....s. 33'-p` „,- n. :l }"ti" Ls y-,.i q. r • 'S:
James B. Hunt,"Governor _- Bill Hoirrlan, Secrel
_ FAX COVER SHEET . `
f, .+y..<. . F "'tr:.l F _. ..... - •. Y Py `T }tl?; . �.. .- •� � n ,.. !H ti � . ..- - ess fi'r. # . - -. � .. �n ..r *_!.� -: a4.. sry,.-'n-�.�av�
-Date: No. Of Pages:
.._-. To: kp,._rnc`6(�Li_ w. ry., From: SEvt�ef;✓4jJ-.rR.,}.�;c
vo
FAX #: D - Z - 5- Z. $ o FAX#: [phone] - -
REMARKS: - .._<./ 1GK'c Q ✓ e,.. �� -f" CGa G,�� r 6 c,r+_-,_�c.S-L
-- }C 5 U ! � � l � � G ✓ . c tJ -t- -r i � 1'1 �- ]'-�//S U � s -1�t v2
L� -f rtn>':'t C - 7r7 �� ��► %,G S lr�Y�rxdT/ TO ,�'UYl �I��SP
Q pL,
127 Cardinal Drive Extension, Wilmington, N.C. 28405-3845 Telephone [phone] Fax [phone]
- An Equal Opportunity Affirmative Action Employer
_ _ . _ «_. � Ja._ w .'_�_i_.:r_. r ._ w - c. � _.ter- _ .: Y .. -- .. -.. _. �..- � .� _. .. ..- .-� - _ _r..._. •.'=.:A%'.i

Mar-• X 4 - 00 08: 36A E nv i roch orn 910 392 4424 P.02
• •
--.094�D'
CONSULTING
CHEMISTS
Customer:
NCDENR-DWQ
127 N. Cardinal Drive Ext.
Wilmington, NC 28405
Attn: Stonewall Mathis
Date Sampled: 03/09/00
Sampled By: Stonewall Mathis
STREAM:
Environmental Chemists, Inc.
6602 Windmill Way - Wilmington. North Carolina 2W5
("910) 392-0223 (Lab) - [phone] (Fax)
[e-mail]
NCD£NR: DWQ CERTIFICATE #94, DLS CERTIFICATE #37729
REPORT OF ANALYSIS
Date of Report: March 14, 2000
RESULTS TO DATE
Purchase Order #:
Report Number: 0-0769
Report To: Stonewall Mathis
PARAMETER
Sample ID
RM Up
RM Down
RMC
Lab m
#1978
# 1979
#1980
Fecal Coliform, colonies/100ml
450
144
18
Nitrate + Nitrite Nitrogen, NO3 + NO2 - N mg/L
Ammonia Nitrogen, NH_,-N, mg/L
Total Kejeldahl Nitrogen, TKN mg/L
Total Phosphorus, P mg/L
�•� 1 /
Reviewed by { ,,3dL �7� r? �`,� and approved for release to the client.

w y
„.,•

+lar--114-00 08 : 36A Env i rochem
910 392 4424
P.O1
CONSULTING CHEMISTS
Environmental Chemists, Inc.
6602 Windmill Way 910.392.0223 phone
Wilmington, 910.392.4424 fax
North Carolina 28405 [e-mail]
facsimile transmittal .................
To: 1Cn e y lIa F-A r -V From:
Company: 1VcjD(=1V a -1-)wCj Date: C20 - Fax No.: `3 S v -a cx� q Pages to
Re: _ �R PS c f /fS _ Follow: �
Mpecaerf-
Ic

M
0 aw
a
Client:
E
4)
s
U
0
c
w
a�
0
0
0
1
ENVIRONMENTAL CHEMISTS, INC
Simple Collection and Chain of Custody
Collected -BY:
Cmmnla Tvnat I = Influant_ F. = F.filnonf_ W =Wp11
cn -Cnil. Ci;.. Ciudaa f1thimr-
6602 windmill way
Wilmington, NC 28405
Phone: [phone]
Pa:; [phone]
Sample Identification
Collection
U�
ca 9
PRESERVATION
ANALYSIS REQUESTED
0
x
d
0
DATE
TIME
TEMP
-P-rl,. t1 F
5 T
19'76 A
ri
G
C
C
G
SOW tLJ
r
G
C
]
✓
c(r,
G
1,14 s
c
G
C
P
G
G
C
P
G
G
C
P
G
G
C
P
G
G
NOTICE — DECHLORINATION : Samples for Ammonia, TKN, Cyanide, Phenol, and Bacteria must be dechlorinated
0.2 ppm Qr less in the field at the time of collection. See reverse side for instructions.
Transfer
Relinquished By:
Date/Time Received By:
Date/Time
i.
2.
Temperature when Received: 1. ° r Accepted: V cted: Resa pie Requested:
Delivered By: Received By. C .. ti`C Date: Time:
Comments:

ENVIRONMENTAL CHEMISTS, INC
Sample Collection and Chain of Custody
Client: AJG D6e08 " DwQ i�J ; •^��� �ah
Collected B: 5 o n e w ct I c4 Ls
s
Sample Tvne: I = Influent. E = Effluent. W =Well. Stream. SO =Soil. SL- Sludge Other:
6602 WindnID Way
Wilmington, NC 28405
Phone: [phone]
Fax: [phone]
Sample Identification
Collection
'
�
g'
�=
Q �
PRESERVATION
ANALYSIS REQUESTED
z
�
gg
o�
d
�q
p
DATE
TIME
TEMP
UP
-G
G
�nU1
C
r/
j7e C.,
G
1 -D
(O w Aj
C
/V U4 r; e s
9MG
Aj
G
G
C
P
G
G
C
P
G
G
C
P
G
G
C
P
G
G
NOTICE -- DECHLORINATION : Samples for Ammonia, TKN, Cyanide, Phenol, and Bacteria must be dechlorinated
0.2 ppm or less in the field at the time of collection. See reverse side for instructions.
Transfer
Relinquished By:
Date/Time
Received By:
Date/Time
1,
2.
Temperature when Received: 1, qq ° G Accepted: cted: Ressple Requested:
Delivered By: o Received Date: 3 q I oo Time: 51
Comments:

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
Rocky Mobley
Gabriel Farms
314 Eneas Lanier Road
Chinquapin NC 28521
Dear Rocky Mobley:
V-7
NU5 •
0,
� ,
j�
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL REsouRcEs
December 30, 1999
Subject: Fertilizer Application Recordkeeping
Animal Waste Management System
Facility Number 31-378
Duplin County
This letter is being sent to clarify the recordkeeping requirement for Plant Available Nitrogen (PAN)
application on fields that are part of your Certified Animal Waste Management Plan.
In order to show that the agronomic loading rates for the crops being grown are not being exceeded, you
must keep records of all sources of nitrogen that are being added to these sites. This would include nitrogen
from all types of animal waste as well as municipal and industrial sludges/residuals, and commercial fertilizers.
Beginning January 1, 2000, all nitrogen sources applied to land receiving animal waste are required to
be kept on the appropriate recordkeeping forms (i.e. 1RR1, IRR2, DRY1, DRY2, DRYS, SLUR1, SLUR2,
SLD1, and SLD2) and maintained in the facility records for review. The Division of Water Quality (DWQ)
compliance inspectors and Division of Soil and Water operation reviewers will review all recordkeeping during
routine inspections. Facilities not documenting all sources of nitrogen application will be subject to an
appropriate enforcement action.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Ms. Sonya Avant of the
DWQ staff at [phone] ext. 571.
Sincerel
Kerr T. Stevens, Director
Division of Water Quality
cc: Wilmington Regional Office
Duplin County Soil and Water Conservation District
Facility File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
February 15, 1999
Rocky Mobley
Gabriel Farms
314 Eneas Lanier Road
Chinquapin NC 28521
ffl IT JW
1 �w"
•
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Im
FEB 1 7 1999
Subject: Application No. AWS310378
Additional Information Request
Gabriel Farms
Animal Waste Operation
Duplin County
Dear Rocky Mobley:
The Non -Discharge Permitting Unit has completed a preliminary engineering review of the subject application. Additional
information is required before we can continue our review. Please address the following by March 17, 1999:
1. When utilizing soybeans in a crop rotation, residual nitrogen should be accounted for in the next crop. It
appears that the nitrogen residual from soybeans is not accounted for in the Waste Utilization Plan (WUP)
submitted. Please contact your technical specialist to review your Waste Utilization Plan (WUP) and revise
the WUP to account for residual nitrogen from soybeans, if necessary.
Please provide an Operation and Maintenance Plan.
Please note that all WUP revisions must be signed and dated by both the owner and the technical specialist. Please
reference the subject permit application number when providing the requested information. All information should be signed,
sealed, and submitted in duplicate to my attention at the address below. The information requested by this letter must be
submitted on or before March 17, 1999 or the Division will return your application as incomplete in accordance with 15A
N.C.A.C. 2H .0200 and your facility will be considered to be operating without a permit.
Please be advised that operation of the subject animal waste management system without a valid permit is a violation of North
Carolina General Statute 143-2t5.1 and will subject you to the enforcement authority of the Environmental Management
Commission.
If you have any questions regarding this request, please call me at [phone], extension 546.
Sincerely,
usan �Cauley
Environmental Engineer
Non -Discharge Permitting Unit
cc: Wilmington Regional Office, Water Quality
Permit File
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Revised April 20, 1999
.JUSTIFICATION & DOCUMENTATION FOR MANDATORY WA DETERMINATION
Facility Number 3 1 - 378
Farm Name: Ce, 6,-+ e.1 qr �
On -Site Representative: —r, k M e6l e
Inspector/Reviewer's Name:
Date of site visit:
Date of most recent WUP:�
Annual farm PAN deficit: 115 pounds
Operation is flagged for a wettable
acre determination due to failure of
P 11 eligibility items) F1 F2 F3 F4
Operation not required 'to secure WA
determination at thi time based on
exemption F1 E2 E3 E4
Operation pended for wettable acre
determination based on P1 P2 P3 .
Irrigation Systems)- circle #. 1. hard -hose traveler; 2. center -pivot system; 3. linear -move system;
A_ stationary sprinkler system wlpermanent pipe; 5. eP-tionary sprinkler system w/portable pipe;
6. stationary gun system w/permanent pipe; 7. stationary gun system w/portable pipe
PART 1. WA Determination Exemptions (Eligibility Tailurc, Pori II, overrides Part i exemption.)
El Adequate irrigation design, including man depicting wettable acres, is complete
and signed by an I or PE.
E2 Adequate D and D irrigation operating parameter sheets including map
depicting wettable acres, is complete and sinned by an I or PE_
E3 Adequate D, irrigation' operating pc-,Gmeter sheet, including map depicting
wettable acres, is complete and signed by a WUP.
EA 75% rule exemption as verified in Part III. (NO T E:7b % exemption cannot be
applied to farms that fail the eligibility checklist in Part 11. Complete eligibility
checklist, Part 11- F1 F2 F3, before completing computational .table in Part 111).
PART I1.751% Rule Eligibility Checklist and. Documentation of WA Determination
Requirements. WA Determinationrequiredbec2use.0pert10n fails fine of the -eligibility
requirements listedl-low:
_F1 L.ck.ofzcreageEwhichTesultedin:over�oplicationmTwasfew2ter_(PAN) on:spray.
field(s)�ccordingfofarm'sdastfwowea��; irricavono-e�ais_-:
F2 Unclearjlleaible,--or lack of information/map.
F3 Obvious:;ieldiimitations-(numerous-diiches;daiiure:to:deauctTequired
buffer/setback-zcreaoe;-or2b%:gflo►al_2creaoeddenffied:in-r,AWMP..:.includes: -
small;-irreaulady-shaped.fields'= fields:less-than-5-acresfortravelers`or.less-than .
2 acres for. -stationary -sprinklers).
FA WA determination required because CAWMP credits field(s)'s acreage in excess
or 75% of the respective field's total acre=fie as rinT=ri in +-_kl-- ;- r)_- F„

Revised AprU 20, I999
Facility Number -
Part 111. Field by Field Determination of 75% Exemption Rule for WA Determination
TRACT
NUMBER
FIELD TYPE OF TOTAL CAWMP
NUMBER'S IRRIGATION ACRES ACRES
SYSTEM
FIELD
%
CCMMENTS3
I
FIELD NUMH"' - ttyc«nt puu, Zorle, or:point numoer- maybe used in plece of held numiers depertdine on CAWMP
and type of irrigation system.- If pulls, etc. cross -more -than one field, insoectorireviewer will have to combine fields to
calculate 75% field by field determination for exemption; otherwise operation will be subject to WA determination.
FIELD NUMHER2 - must be clearly delineated on mep. T- - y.,
COMMENTS' - back-up fields with CAWMP acFe geWxceeding75% of its total_acres—enth
d havingreceived less a:i 50%
of its annual PAN as -domimented in the farm's 7previous-two years' (1997 & .1898) of imgationTecords, C2nn0t 5crve"a5'the
sole basis -for requiring a WA Determinabon_:BacKfi -uoelds mus`-benoted in the -comment:se:.vonznd.mustbe accessible
by irrigation -system. -
Part IV. Pending WA Determinations -
Pi Planlacks Sollowina information:
P2 Plan Tevision may_s2tsfy?5% rule based on adequate overall PAN deficit and by
adjusting all field mcreageJo below 73% use rate
- F3 Other (ie iin process of installing new irrigation system):

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
Rocky Mobley
Gabriel Farms
314 Eneas Lanier Road
Chinquapin NC 28521
Dear Rocky Mobley:
1 � •
f
NCDENR
NORTH CAROLtNA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Marcl r� c ed :1\6 �00-
� � cl�� C&t
(QUO �"' W av-v
Subject: Certificate of Coverage No. AWS310378
Gabriel Farms
Swine Waste Collection, Treatment,
Storage and Application System
Duplin County
In accordance with your application received on January 28, 1999, we are forwarding this Certificate of
Coverage (COC) issued to Rocky Mobley, authorizing the operation of the subject animal waste
collection, treatment, storage and land application system in accordance with General Permit°
AWG100000. This approval shall consist of the operation of this system including, but not limited to,.
the management of animal waste from the Gabriel Farms, located in Duplin County, with an animal
capacity of no greater than 600 Farrow to Feeder and the application to land as specified in the Certified
Animal Waste Management.Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This request
shall be made within 30 days of notification by the Division.
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Certificate of Coverage AWS310378
Gabriel Farms
Page 2
This COC is not automatically transferable. A name/ownership change application must be submitted to
the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual non -discharge permit by contacting the engineer listed below for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
The subject farm is located in the Wilmington Regional Office. The Regional Office Water Quality Staff
may be reached at [phone]. If you need additional information concerning this COC or the
General Permit, please contact Susan Cauley at [phone] ext. 546.
Sincerely,
A. Preston Howard, Jr., P.E.
cc: (Certificate of Coverage only for all cc's)
Duplin County Health Department
Wilmington Regional Office, Water Quality Section
Duplin County Soil and Water Conservation District
Permit File
NDPU Files

State of North Carolina
Department of Environment and Natural Resources
Division of Water Quality WgrRe1VEb
Non -Discharge Permit Application Form
(THIS FORM MAYBE PHOTOCOPIED FOR USE AS AN ORIGINAL) f
General Permit - Existing Liquid Animal Waste Opel lh,16S 999
Afor' The following
questions have been completed utilizing information on file with44fo1�i,oQ. Plea
review the information for completeness and make any corrections which are appropr4i U. If a
question has not been completed by the Division, please complete as best as possible. Do not leaf
any question unanswered.
1. GENERAL INFORMATION:
1.1 Facility Name: Gabriel Farms
1.2 Print Land Owner's name: Rocky Mobl
1.3 Mailing address: 314 Eneas Lanier Rd.
City, State: Chinquapin NC Zip: 28521
Telephone Number (include area code): 910-285-7159
1.4 County where facility is located: Duplin
1.5 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads. Please incl&
copy of a county road map with the location of the farm identified): from chinquapin take NC 41 N to Beulaville abou
mile out of town bear right onNC 1115 for .5 mile, turn rt. on SR 1817, go 3.5 mi. to farm entrance on right
1.6 Print Farm Manager's name (if different from Land Owner).
1.7 Lessee's / Integrator's name (if applicable; please circle which type is listed): Murphy Family Farms_
1.8 Date Facility Originally Began Operation: 01/01/86
1.9 Date(s) of Facility Expansion(s) (if applicable):
2. OPERATION INFORMATION:
2.1 Facility No.: 31 (county number); 378 (facility number).
2.2 Operation Descrlpbon: Swine operation
-TM--Tow to Feeder
600- Certified Design Capacity
is the above information correct? 56es; E no. if no, correct below using the design capacity of the facility
The "No. of Animals" should be the maxurturn number for which the waste management structures were designed.
Type of Swine No. of Animals Type of Poultry No. of Animals Type of Cattle No. of Anim
Wean to Feeder Layer Dairy
Feeder to Finish Non -Layer Beef
Farrow to Wean (# sow) Turkey
Farrow to Feeder (# sow)
Farrow to Finish (# sow)
Other Type of Livestock on the farm: No. of Animals:

3.
2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): 1697 , Required Acreage (as listed in the AWMP): 15.96
2.4 Number of lagoons/ storage ponds (circle which is applicable): 5�'t" A��
2.5 Are subsurface drains present within 100' of any of the application fields? or NO (please circle on.
2.6 Are subsurface drains present in the vicinity or under the lagoon(s) 7 ` YES o NO)(please circle on
2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, NRCS Standards, etc ) (Swine Only)
or NO (please circle on,
What was the date that this facility's swine houses and lagoon were sited? //i�7
What was the date that this facility's land application areas were sited? 08121— di7
REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to eac
item.
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). if the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit
application for animal waste operations.
The CAWMP must include the following components:
3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3 2 The method by which waste is applied to the disposal fields (e.g. irrigation,
in}ection, etc.)
3.3.3 A map of every field used for land application.
3.3.4 The soil series present on every land application field
3.3.5 The crops grown on every land application field
3 3 6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application field.
33.8 The waste application windows for every crop utilized in the WUP.
3 3 9 The required NRCS Standard specifications,
3.3.10 A site schematic.
3.3.11 Emergency Action Plan,
3.3.12 Insect Control Checklist with chosen best management practices noted.
3.3.13 Odor Control Checklist with chosen best management practices noted.
3.3.14 Mortality Control Checklist with the selected method noted.
3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility.
3.3.16 Operation and Maintenance Plan
If your CAWMP includes any components not shown on this list, please include the
additional components with your submittal
FORM: AWO-G-E 5R8/98 Page 2 of 4 31- 378
Applicants Initials
of
P111 1" .

Facility Number: 31 - 378
Facility Name: Gabriel Farms
4. APPLICANT'S CERTIFICATION:
1, RV&k." lrb'ol e'y _ (Land Owner's name listed in question 12). attest
this application for 1 4W AT'o'15 (Facility name listed in question i
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned to mef incomplete.
16,
Signature Date f ]~yl
5. MANA R'S CE TIFICATION: (complete only if diffcaent from the Land Owner)
1, _ T (Manager's name listed in question 1.4 attest that t
application for (Facility name listed in question I
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned as incomplete.
Signature Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
WATE ""A('Ty E �10N
QAN 2 8 1999
Non -Discharge Permitting
FORM: AWO-G-E 5f2"8 Page 3 of 4 31- 378

DIVISION OF WATER QUALITY REGIONAL OFFICES (M
Asheville Regional WQ Saptrvisvr
59 Woodfin Place
AdwvW NC 28801
C704) 251-6=
Fact (7004) 251-W2
Avery
Buncombe
Btnka
McDowell
Caldwell
Mitchell
Cherobea
Polk
Clay
Rud=ford
efflahmn
swain
Haywood
Tr=Wvania
Henderson
Yancey
Jackson
Fa}efteville Regional WQ Supervisor
Wachovia Building, Suite 714
Faye Mr lle, NC 2&401
(910) 48trr1541
Fax (910) 48&0707
Wallington Regional WQ Supervisor
943 Washington Squam Mall
Waalti gw& NC 27889
(919) 9464"1
Fax [phone]
Beaufort
Bade
Jom
Lenoir
Camden
C,htiwaa
Martin
Pamlico
Craven
Pasquounk
Cuniurdk
Pavlimw
Imm
An
Gates
Tyre"
c eeae
Washiustoti
Hadbr+d
Wayne
Hyde
MomuviUa RegimW WQ Supervisor
919 North Main Street
MomesvilK NC 28115
(704) 663-16"
Fax [phone]
Raleigh Regional WQ Supar visor
39M Banner Dr.
Rdeigh, NC 27611
('919) 571.4700
Aw [phone]
Can Nash
Durham Northampten
FAgwombe Orange
Fiaaklin Ferran
Manville Vaaoa
Halifax wake
i,ft eon Wawa
Lee Wilm
Wilmington. Repjae,. WQ Sapwdsor
127 Cardinal Drive Fsstendon
Wilmington, NC 294 5--3945
(910) 395-3M
Fax (910) 350`2W4
Aaron Moore Alexander Lincoln Brunswick Now Hanover
Bladen Richmaad Cebmw Medcienbarg Carter Ooalow
Cumberland Robeson Catawba Rowan COlmabus Pander
Harnett Sampson Clevelaad Stanly Duplin
Hake Scotland Gaston Union
Montgomery undrll
Winsto�Salem Regional WQ Supervisor
585 Waughtown Street
Winston-Salem, NC 27107
(910) 77146DO
Fax [phone]
Rodangham
Allepany Randolph
Ashe Stakes
Caswell Surry
Davidson Watauga
Davie Willow
Forsyth Yadkin
Guilford
FORM: AWO-G-E S128f98 Page 4 of 4

Producer: rrl4JJ1.40-1
Location: -9 i. J^eS LaA e.r P-J .
j�.k. 0-1 x.p-A, rU e- >rd!� f
Telephone: L ro) sgf yl99
Type Operation: +-, "--e-e�
Number of Animals: &a>
(Design Capacity)
WATERtQUALILITYSED ION
FEB 2 5 ;999
1> µ,A " 6Ur;-Discharge Permitting
The waste from your animal facility must be nand applied at a specified rate to prevent
ppliunion of surface and/or groundwater. The plant nutrients in the animal waste should
be used to reduce the amount of commercial femlizer required for the crops in the fields
where the waste is to be applied. This waste utdizadon plan uses nitrogen as the limiting
nutrient. Waste should be analysed before each application cycle. Annual soil tests are
strongly encouraged so that all plant nu netrts caa be balanced for realistic yields ofthe
crop to be grown.
Several factors are important in implementing your waste utilization plan is order to
maximize the fertilizer value ofthe waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the needs ofthe crop to be
grown and the nutrient content of the waste. Do not apply more nitrogen than the crop
can utilize. Soil types are important as they have different infiltration rates, leaching
potentials, cation exchange capacities, and available water holding capacities. Normalcy
waste shall not be applied to land eroding at greater than 5 tons per acre per year. With
special precautions, waste may be applied to land eroding at up to 10 tons per acre per
year. Do not apply waste on saturated sons, when it is rainnag, or when the surface is
frozen- Either of these conditions may result in runoff to surface waters which is not
allowed under DEM regulations. Wind conditions should also be considered to avoid drift
and downwind odor problems. To maximize the value of nutrients for crop production -
and to reduce the potential for pollution, the waste should be applied to a grooving crop or
applied to bare ground not more than 30 days prior to planting. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. Acreage requirements should be based on the waste analysts
report from your waste management facility. Attached you will find information on
proper sa.mEphug techniques, preparation, and transfer of waste samples to the lab for
analvsis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A
NCAC 2H.021 T adopted by the Environmiental Management Comaiission.

Amount of Waste Produced Per Year(gallons. ft; toru, etc. )
l �
-L2p— animal S X3armt} wastelanimaUyear=�,3'b, 9°` waste/year.
Amount of Plant Available Nitrogen (PAN) Produced Per Year
boo animals )� .�Ib& PAN/auimallyear = 3900 lbs. PAN/year- (PAN from N C. Tcch.
Guide Std 633)
Applying the above amount ofwaste is a big job. You should plan time and have
appropriate equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on the crop to be grown
and scface application:
Table 1. ACRES OWNED BY PRODUCER
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
# No. Type Per Ac * Utflized Application
��1l1
M
N
"maw---
F�
Total l?. 1
* This N is from animal waksu only. If nutriena from biher sources such as comrna'cW
fertUize► are applied, they must be accounted for. N must be based on reaUt is icld
ectaaioz
NO The applicator is cautioned that P and K maybe over applied while meeting the N
requirements. Beginning in 1996 the Caastal Zone Management Act will require fwwwn in
sonre eastern counties of North Camfinn to have a aunieret maxagemeni plan that addresses
all nurrienu- This plan only addresses Nitrogen.

M, M ! �, • _
''. 'o. ^' � e ��..j 3::r�.. � ->y _Z %Yil .iiYr� :: =_'�'•+�.�:�h��- � «r :,.`. '�."�"`�s.�ti.�:�.'*,�,>i
Table 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Ageement with adjacent landowner mast be attached)
(Required only if ope=r does not own
u6gm a land (see Requuvd 5peciEc=ou xJ)
Tract Field Soil Crop Lbs. N Acres Lbs. N Man& of
* See foolnote for Table L
Totals from above Tables
Ades Lbs. N
Utffized
Table 1
Table Z
Total
Amount of N
Stuphis o
Produced
or.�
NOTE: The Waste Ulilizaiion Plan must contain provisions for periodic land
application of sludge at agronomic rates: The sludge will be nutiriem rich and P411
require precautionary measures to prevent over application of nutrients or other
ekmenm

_ "�;. s � �� :� �> . _ w �"' :•-"li � i,C C r � -�3s � .�� �'�,` ' SSYt+ �'Z.i'�. ;—s.`s:�• w...,:.,..'�' ;z .,,..,
See attached map showing the fields to be used for the utiUw on of waste water.
Application of Waste by Irrigation.
Field Soil Type Crop Application Application
No_ Rate (In/Hr) Amouq (IL)
3 5—
. S
= TAME IS NOT NMW IF wASM S Mr BMXG AgP= BY =WMCW.IMWEvF.ltA SUMAR TABLE VM.L.
Hi3NEEDED FOR DKYInTFB OR ST.i =Y.
Your facility is desigaed forj�,, days of temporary storage and the temporary storage
most be removed on the average of once every_ h: MONTHS. In no M 9touid
19" �• a r- f -.'-
the
voh=e of waste being stored in your structure exceed Elevation ,.� WL- , 44 t%�L.
Call the local Natural Resources Conservation Service (formerly Soil Conservation
Service) or Soil and Water Conservation District office after you receive the waste
analysis report for assistance in deterniining the amount per acre to apply aid the proper
application rate prior to applying the waste.
�K'i 1 �rJ, M�1• i4
f . + cs, rf L17✓� ��i L -rot

rli '� ,. .. .. rye .? %s i" •:r�z:,c —
REQUIRED SPECIKCATTONS
I. Animal waste shall not reach sin -face waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or Land
application. Any discharge ofwaste which reaches surface water is prohibit
2. There must be documentation in the design foider that the producer either owns or has
an agreement for use of adequate land on which to properly apply the waste. If the
producer does not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a reasonable
proximity, allowing hatn/her the use of the land for waste application. It is the
responsibility of the owner of the facility to secure an update of the Waste Utilization
Plan when there is a du mge in the operation, increase in the number of animals,
method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic
crop yields based on soil type, available moisture, historical data, chmatic cc mditions,
and level ofmama gemeut, unless there are regulations that restrict the race of
application for other ntutzients. '
4. Animal waste shall be applied to land eroding less than 5 tons per acre per year.
Waste may be applied to land that is eroding at 5 or more tons, but less than 10 tons
per acre per year providing grass filter sups are installed where runoff leaves the field.
(See FOTG Standard 393 - Filter Strap).
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
b. When animal waste is to be applied on acres subject to flooding, it will be soil
incorporated on conventionally tilled cropland. When applied to conservarian tilled
crops or grassland, the waste maybe broadcast provided the application does not
occur during a season prone to flooding. (See "Weather and Climate in North
Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
runoff does not occur o$she or to surface waters and in a method which does not
cause drift from the site during application. No ponding should occur in order to
control odor or flies.
8. Animal waste shall not be applied to saturated soils, during rainfall eveuts, or when the
surface is frozen.

.:ii. -. C.-."�'^-..^C^:f:.�].
1
REQUIRED SPECIFICATIONS
(continued)
i 9. Animal waste shall be applied on actively growing crops in such a meaner that the
crop is not covered with waste to a depth that would iahrbrt growth. The potential for
salt damage from animal waste should also be considered.
10. Waste m=ients shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leachm* Waste mmient loading rates on these sods should
be held to a and a suitable winter cover crop ]anted to take released
� aP P up
nunrients. Waste shall, not be applied more than 30 days prior to planting ofthe crop
or forages bruld mg dormancy.
11_ Any new swine fhcflity sited on or after October 1, 1995 shall comply with the
following The outer perimeter of the land area onto which waste is applied from a
lagoon that is a conponeat of a swore farm shall be at least 50 feet from nay residential
' property boundary and from anyperennial stream or river (otherthan an irrigation
ditch or canal. Animal waste other than swine waste from des sited on or after
October 1, 1995), shall not be applied closer than 25 feet to perennial waters. (See
Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and public riOvof-
ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands
by a discharge or by over -spraying. Animal waste may be applied to prior converted
wetlands provided they have been approved as a land application site by a "technical
specialist"_ Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall, be applied at
agronomic rates in a meaner that causes no runoff or drift from the site.
16. Domestic and industrial waste from washdown facHities, showers, toffs, sinks, etc.,
shall not be discharged into the animal waste management system

REQUIRED SPECIFICATIONS
(continued)
18. If animal production at the fac ilky is to be suspended or terminated, the owner is
responsible for obtaining and 2mplementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, ping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leafs, and spxiUs. A regular maintenance checklist should
be kept on site.
20. Auroral waste can be used in a rotation that includes vegetables and other crops for
direct human consunVtion. However, if animal waste is used on crops for direct
human consumption it should only be applied preplant with no farther applications of
animal waste during the crop season.
21.11ighly visible markers shall be installed to mark the top and bottom elevations ofthe
temp orary storage (pumping volume) of all waste treatment lagoons. Pmmping shall
be managed to maintain the liquid level between the markers. A marker wM be
required to mark the max== storage volume for waste storage ponds.
22. Waste shall be tested within 69 days ofumlizatim and soil shall be tested at least
annually at crop saes where waste products are applied.. Nitrogen shall be the rate_
determining element Zmc and copper levels in the soils shall be monitored and
alternative crop saes dull be used when these metals approach excessive levels. pH
shall be adjusted for opt nnrm crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry waste application records
shall be maintained for three (3) years. Waste application records for all other waste
shall be maintained for five (5) years.
23. Dead animals will be disposed of is a manner that meets North Carolina regulations

WASTE UTILIZATION PLAN AGREEMM9
Name of Farm: (�' "bxJ rxmt _
Owner/Manager Agreement
I (we) understand and will follow and implement the sp ecificatim and the operation and
maintenance procedures established is the approved anianalwaste ubon pion for the
fawn named above. I (we) know that any expansion to the existing design capacity ofthe
waste treatment and storage system or constmaicn ofnew facdrties wM require anew
certification to be submitted to the Division ofEuvironment Management (DEM) before
the new animals are stocked I (we) also understand that there must be no discharge of
animal waste from this system to surface wasters of the state from a storm event less
severe than the 25-year, 24-hour storm. The approved plan will be filed on -site at the
farm office and at the office of the local Soil and Water Conservation District and will be
available for review by DEM upon request.
Name of facility Owner. P;&-J J ; e� 4415c,
(Please print)
Signature: Date:
Name of Mmapfff difi mw from owner): . _ � y _ iJo jam_
Signature: Date: _- 7 1 w
Name of T Specialist (Mare print) wry S5 . w _
Affiliation: M,,,r. r.�� i•e. r-M�
Address (Agency):
Signature: J�nk■ Date: a Y 9 7 4
6 •. .t s�+� !

REC 2 IVED
NAME: Freddie Ha i su WATrROUAUTYSECTION
ADDRESS:
I YPI= OF AND S ] IE
OF OOP RATION: FARRow rU FEEDER i-' 1 uS NO. Rion-Disch�.rge F�ermilting
CLASS. As - Built Construction Cher- •
DESIGNED BY:
DATE:4-17-86
APPROVED BY:
DATE:
PERMANENT STORAGE
oqs X b2'2 1 b5. per hog X 1 Cu Ft per lb.
fEMPORARY STORAGE
267,088 lbs Uf animal wt. X 1.35 cu. ft. U+ waste Per
day per W00 lbs. animal wt. X 180 days
f;AINFOLI L-EES EVHFORATION
I" X 54696 sy. ft. of surface area tpor 12"
- per ft.
RAINFALL - 25 t R. { DAY S FORM
7. 3" X 5469ri =;q . f t 0+ stir -Face ar ec+ per 1
per f L.
TOTAL 5IURAUE NEEDED
TOTAL STORAGE AVA 1 L ABLE
AMOUNT OF FILL D I KE
PAD
TOTAL
SETTLEMENT 10%
TOTAL AMUUNT OF FILL
CUT . FILL RATIO TOTAL EXCAVATION
0.82 . 1
3 I J 1-00
263088 Cu. Ft.
63,930 Cu. F t .
J-1906 Cu. Ft.
7�4185
Cu.
Ft.
9�7109
Cu.
Ft.
14560
Cu.
Yds.
430944
Cu.
Ft.
15961
Cu.
Yds.
102931)
Cu.
Ft.
2.31856
Cu.
Ft.
334786
Cu.
Ft.
33479
Cu.
Ft.
368265
Cu.
Ft. f q4,a G
13639
Cu.
Yds. -f123'
303650
Cu.
Ft.
11246
Cu.
Yds. .2�1

aar�E:
VOLUME = DEPTH I AREA OF TOP + AREA OF BOTTOM f 4 X AREA OF mID-SECTIOR I
a 27
VOLUME = DEPTH f L I R + L I Y + 4 1 L I � }
6 27
51f�Q LA I ��5 i YO,oao
VOLUME = 7.5 I 250.0 x 204.0 + 225.0 X 103.0 + 4 X 250.0 X 180.0 ]
6 27
4OLUKE = 9.5 E 272175 1
6 27
VOLUME = 430744 CU. FT.
27
VOLUME = 15961 CU. Y85
54696 sq. ft 66091 cu ft needed

HARE
AREA CALCULATION
EXCAVATION
AREA CALULATION
PAD
I
X Y
1
X
t
1
0.0 0.0
1
0.0
0.0
2
1.0 -0.2
-0.4
2
0.8
0.1
0.2
3
2.0 -0.4
-0.4
-0.9
3
1.8
0.3
0.2
1.0
4
2.2 -0.6
-1.2
-1.4
4
3.2
0.5
0.9
1.6
5
2.3 1.2
2.6
2.4
5
3.1
0.9
2.4
2.1
6
2.0 1.6
3.6
1.6
6
2.3
0.9
2.8
1.2
7
1.0 1.6
3.2
0.0
7
I.3
1.0
2.3
0.3
8
0.0 1.2
1.2
0.0
8
0.3
0.9
1.2
0.0
9
0.0
0.0
9
0.0
0.0
10
0.0
0.0
10
0.0
0.0
11
12
9.0
1.4
11
12
10.3
6.2
13
13
14
AREA IN 99UARE 1%.
3.8
14
AREA IN SQUARE 19.
2.0
AVERAGE END AREA
1.0
1534.0
AVERAGE END AREA
1.0
810.0
:MOUNT
EXCAVATED 1534.0
190.0 291460.0
ANIJUNT
IN PAD
810.0
260.0 210600.0
;fiEA CALULATION
EXCAVATION
AREA CALULATION
PAD
1
X Y
1
X
Y
1
0.0 0.0
1
0.0
0.0
2
1.8 -0.4
0.7
2
1.2
-0.4
-0.9
3
1.8 1.0
2.4
2.1
3
2.2
-0.6
-0.7
-1.6
4
1.3 1.7
5.1
-0.3
4
-.7
-0.7
-1.5
-1.9
5
-0.2 2.0
2.6
0.0
5
2.7
-0.1
-0.3
-0.3
6
0.0 0.6
0.0
0.0
3
2.4
-0.1
-0,3
-0.1
7
0.0 0.0
0.0
0.0
7
1.4
0.5
1.2
0.2
8
0.0
0.0
6
0.4
0.9
1.3
0.2
4
_
0.0
0.0
9
0.2
0.8
0.3
0.0
10
0.0
0.0
10
0.0
0.0
ii .
11
12
8.5
1.0
12
-0.1
-4.4
13
13
14
AREA IN SOME IN.
3.8
14_
AREA IN SQUARE 10.
2.2
AVERAGE END AREA
1.0
1504.0
AVERAGE END AREA
1.0
872.0
-�4GUNT EXCAVATED
1504.0
210.0 315840.0
AWOUNT IN
PAD
872.E
290.0 253112.0
AVERAGE EXCAVATION
303650.0
AVERAGE IN
PAD
231856.0

AREA CALULA7ION DIKE
I x Y
1
0.0 0.0
2
0.3 -0.1
.0
3
0.2 1.1
0.3
0.0
4
0.0 1.1
0.2
0.0
5
0.0 0.0
0.0
0.0
6
0.0 0.0
0.0
0.0
7
0.0 0.0
0.0
0.0
8
0.0
0.0
q
0. D
0.0
10
0.0
0.0
11
12
0.6
.0
13
14
AREA IN SH{IARE IN.
0, 3
2
>< r
----------------------------------------
1
0.0 0.0
2
0.4 -0.6
-0.2
3
0.3 1.5
0.6
0.2
4
0.1 1.3
0.4
0.0
5
0.0 0.0
0.0
0.0
6
0.0 0.0
0.0
0.0
0.0 0.0
0.0
0.0
g
0.0
0.0
9
0.0
0.0
10
0.0
0.0
11
12
1.0
.0
13
14
AREA IN SAi1ARE IN.
0.5
�
z r
1
0. D 0.0
2
0.4 0.0
0.0
3
0.3 I.2
0.5
0.2
4
D.z 1.2
o.4
0.0
5
0.0 0.0
0.0
0.0
6
0.0 0.0
0.0
0.0
7
0.0 0.0
0.0
0.0
8
0.0
0.0
9
0.0
0.0
10
0.0
0.0
1!
12
0.8
0.2
13
14
AREA IN SGUARE IN.
0.3
AVERAGE END AREA
3.0
146.0
IOUNT IN DIKE 146.0 705.0 102930.0

NAME: FrF-ddJ e Halso
ADDRESS: Ch x nquap i n , N.C.
$ YPF UF= AND 5 I Z E
UF OPERA IEJN: Fill-(RUW TO
FEEDER , F-J B8 NO. t,04
CLASS: I I T
DESIGNED BY: F.enneth R.
Futreal
DATE": ;--24-86
APPROVED BY: Venrieth ;;'.
Flttreal
DATE:,-25-8o
PERMAMENT STORAGE
504 Hogs X 522 lbs. per
hog X 1 Cu. Ft. per lb.
267088
Cu.
Ft.
TEMPORARY STORAGE
2630E�8 lbs r,� a��mal w# . X
1.=�� cu. fit. q� waste per
6_930
Cu.
Ft.
day per 1000 1 bs. animal wt . X ISO days
RAINFALL LESS EVAPORATION
7" X 51084 sq. ft . c,f
surface area t)c r 1 "'
.'9799
CLL.
Ft.
- per ft.
RAINFALL -- 25 Y R . t DAY STORM
/.-5 X 51084 sq. Tt •rF sLirf,Ftca ;tr-ea per 1s!"
31978
Lu.
Ft.
pev 4 t.
TOTAL STOkAVE NEEDED
?.HB-745
l_.ct.
F t..
14 a98
Cu.
Yds.
TOTAL STORAGE AVAILABLE
:sy -333
Cu.
Ft.
145�1
Cu.
Yds.
AMOUNT OF FILL D l P E
8o750
Cu.
Ft.
PAD
1 d i O' >
Cu.
Ft.
TOTAL
7'61750
Cu.
Ft.
SETTLEMENT 10%
26175
Cu.
Ft.
TOTAL AMOUNT OF FILL
._'BYc?25
Cu.
F t .
1(.)664
Cu.
Yds.
CUT FILL RATIO
TOTAL EXCAVAI ION
-_168475
Cu.
Ft.
• 1
13647
Cu.
Yvs.

NAHF: F•rHdodi & Hrtt -.o
APPRnx i MATE NI TRfiGFN i.( N I ENT THOT WILL BE F-RUDUCED F'F R YEAR
Ni mOCiEN (14) — 0.42 LHS F'ER 1000 LRS OF ANIMAL Wl . A —�65
DAYS
(N) --0. 48 X 2,630F S
-------------------------------
1 o j%
(N)—4609LBS
I T I S FST I MATED 1 F AT r5f'F= RO X T InAl EL s' UF- T HE hl J I ROJGE W W I L1
HE AVAILABLE FOR IJSE AS FERT'ILIZEFt
THE FULLOWINS AMOUNT CAN BE AF-PI IED ON THE LAND
1 15C 1 L9S.
IF APPLIED AT 1 HE RATE OF 200 L HS PER ACRE. UN CROPLAND l HE N
58 ACRES WILL BE NEEDED TO rAF.E CARE OF THE EFF LE IF NT.
IF A'r-'P .lED AT THE BATE OF 44-is=l LF:S PER ACRE ON Pry-'-rIUi1L.i_h1NL} lrit-N
w9 ACRES WILL BE NEEDED FO TAF E CARE OF THE EF F LUE-M F.
BEFORE ANl' EFFLUENT I'.•a APPL J En ro THE LAND 11 SHOULD BF
ANALYZED TO DETERM ENE TF L EXA T I'•JUTI RJ ENT CON T EN7 . THE NCDIy
LABORA FORY IN RAL E 1 GH J.:i iAi. J EG 3%){".E. T FST ON r^d LIMITED PAS I S.
YOU SHOULD CONTACT (AGR0N'GM J C SERVICES DIVISION
(NCDA . BLUE RIDGE RUAD CENTER ?
(RALEIGH, N.C. —761 1 )
(F'HUNEa
WHEN APPLYING 1'HE EW FFLUEI,,IT TO CROPLAND IT SHOULD BE DISK AND A
COVER LROP SEEDED OR A ROW CROP r= i._AN i ED TO F Rk VF N'I � I' o f; 1 014
WHEN AP -PLYING TO PASiUF-.E LAND APPLY AT A SLOWER RATE IN ORDER
TO MINIMIZE ANY RIJNOF-I-.
SOME OF THE EFF L F DENT LOULD BE USED FOR 1 KN J GA F 1 ON F 'URK)SF= E;
DURING THE GROWING SEASON.
BEGIN PUMPING lHE FFF'J LIENT WI-IErJ r4i7L J"'LUID LEVEL REACHES
I�A4ye Ape DO NOF LOWER THE FLUID LEVEL ANY LOWER THAN
/,Y/ BELOW ]FIE OUTLET PIPE.
6

NAME:
SE ELi 1 NU SF't" [; i- f E :fl I IONS
AREA TO BE SEEPED
Ath-*PLY THE FOLLOWINS
USE THE Sc ED MIXTURE
INDICA I ED
i }
4 )
f )
( )
LBS.
B—H—fi
FER'i J L J /FR
6.0
TONS
OF
DOLOMITIC L I MESI ONE
240
BALE
OF
SMA1 L UKF4I N STRAW
J Ufa
LBS.
FESCUE URASS
105
LBS.
OATS
154
LBS.
BAHIA GRASS
12
LBS.
WEEPING LOVE GRASS
716
LBS.
HUL! .Eli CUf" MON BE+• MUOR
75
LBS.
UNHULLED COMMON BERMUD
DIVERT ALL SURFACE wm Eh TD A STABLE OUTLE!.

ItiT
Di
tT
�� ) � -----------------�--�'—~-- --�--'-- -�--'
^u,'.,.oL.u'
"°3ozLs/0 .'*..' ,"^^n w»y,-L310 onum^ "'.

• - _ •r- , ...I.. i .�i'" .i. 1�11 ,I: i I� ', 1, �I II' !' !� � l' i I' � � I .'• �; ! I i
-- - -i-T- ..._'r._. ill •1��� -� :'''i, -'I, '`�'' it � •I,4:I ... '�! i•'I �' Ir; .:i �p
__�'.._. $ ___.._ - _.-._ __ l � _I.. fff �• '.'� .�' I �1 i 1 I I, .. ,. .� .,.1 i .I.. + .�_.. I.i. ...i_.
77
CY
h I
N
1 -i'• _r _ -- —�I- `I _�• •.4.•`- •-r !� i j l; - '�I _ _• '_ _ .-'.I_ --_ _ I '
Ll-ri`
I Vr i'li '' ,li it I f i i i�� i i i � i'i , .� i� •'r ' .� L'.�S (j
v m n wo io— How t13d WZ X rje
Nf]I1vN0dUOZ, N3n213IQ rl-7,'�. I 1-idvuD N2E3Z131t1 11�•tllll'l' I'frl

NO ; 411P-20 VIETZGEN GRAPll PAPhU
211 X 20 PER INCH
UIETZQEN GORPORAIMN
«roc IM u , ..
�2� 1 O
T!III
77
T-7—
7, �ili
r :,
II lil
i.l
Li
•i
1 1
77
'1
I •
1I.
al
lb
Im
�5

-' {;.Il{ II!,
S It 1
TT
�
!.TC
1-. i//-� • l .1- +-
- :. i• .y.l .Ir I 1-�-I ..l '�:}� :I "i ?{�7 rl,, -7+ slhl ,' •irl �V }.,r +� . ' 1i~ .i. I,. �, -- i - � i —---+---•-•--�--�^--
�:-rf• ': : ' }..:-i�' .LC •� f,, t; 1 :•II 'j I �I t:ll '' �i I� I ''i, :I' I .,; i .I:! r .,
:1., .i:��;r fit, �; �a i; �' , lr:; i�'� ;�, ;{• i71t �i'` 4!,� li', ,;� l' '' •t{I °`i.s 'I;, �; •1. , ::: l .I' � ' - �
1' •h-` , :ti — _ t,! '7,; ,il •li{' i ` ;r' F1' j;i, 11 1., I, ',,1 I:i�ri j 1 ; I I i r
I ,- -i' i,. `i - _,_ "„S _ i _:I ! }, .i-i{' •. .q' � . 4 .-;•r I 1 � _ V i' � � ,
• — TiI" '~! :i {c. I. 'i� I'1 ,j7; �I+� :71'; il;i ;t ,i F:•;;I: :,. ,1.,i i I .. t _i_ 1 .. i--
-
Ir
:'tT— iL ii --'I { t :t• '71 :+• •. 1ir l I ,t ._ + j_. 1' — — _.
.. I ' t 1 ' ' • ` , i ' ,1 ._� -- - " 1 ice.. � -";k - .. �.,-... _ _ � i . .._.��.�_ - -� - - _7-•- _ � _' _ _ . I — _-_ ' — .:.. �-_ _
71
�'.�_ •_.'�. •-_ '-i- I�V� ..;.1...+�. _,� _ II •• ',:'i r: .I, j I '�, I I I I r 'k i r �-�
.'1 '',' _tii.r {' � - yi -�' ' r � 1 i ' � 1. ' r , 7 �; , ; � �..�-�_ _�:_.-..: ._- - -• ---- -- ..__-i._.� .. r — i---1._._..
rit"
K
-t •�;+ :1; �1,1;� ,1.� r �� .,r �-;$� :t;i 17: 'I'� ij.t 'I� �: � ', ..'�1 i ��{ -' � r t'
-- �•±•t:;;; �'-`1'-�-"I ;,,r , li'?µ illi �< i'", 11� 11�• 11� I! .'I:. 3i _ `
• n ti, 7avw HJN1 IlJd 42: A J:
NOLLtl Llf]dkid3 N3OI.l.Jld el-4,1V,4 firldt{l-•F N3071310 OZ-TIUt•F ,)t,

5�
f!J
"10
3
gr
Yj
1 • 1
•I�r
! � I•
�
h: ; �
.
,!
;�a.
l I
rl i
-t f
Y��
r,
, }
�
} 1 1 1
t
1-• ,
I
I r
y I 1
•��
,f.l
•a. '?'
•y.!
rf,�
4i �H
i �
i��,
„
't.'1}
-
I.� !!
1. i.
1
•sir
t
,' 1
1
E
Y
I I�
`1
'-
�•3i
-i
jr
'•1.
1
S4E,
,t�'
,,.�,
{I1
1µµr{1y
.I'
. a.•"..
:yl :
_
+~i'•
".
..1.�
: i
_,•
}I •:
VI',
, t ,tr
." I
+.1H_J+I
f
't. •t
.{-1 . �i
{t
t_,
r' f l
'
,y -i•
; r i
♦
77
r
.� ''
.1 1
1_jE
�.
,�
�...: I{•'�'t,
IT'rfh
,1�
if.1l.
IM
L _.i
I..
•IL-1,-..>
7 1;
•...
i''
:1,
',�
!a
T1
1}
;;.S
'1 -,-� T
t.I1
1
r!'
'1
ill
'
`'
;•
t.
' �I
.r:!
I,
;1
r+-}
"
}
i?I
:!
r•;
1!,t
1.1,
1
;,
11
!
-
�i'
I' 4
Ijji
;{
•I'
•t'
!�:
'!':
t{I!
'i�'1�,
lil
:t
To
,I�
t4il,
it i
1
i', iGl
t_'�I i Ili "•+_ II 4 '�i7 i ,•„ , •I
4!t' ���` :li;;,l '•, ! II I'i�• � .I •� .. It
.;� 1--..1.._T�.}_�•_ _ ._._.�_--...
y�,t111. -i;•! ,T� iFE` :1.,.. il'�� .. "•:,��r._` �� ill: } 1_...�.,. _ `�. '1 ,�__ } _ -i __
y�.•�.i'i, •F4{-. '���- •:.1�_ i; '•T; ..:�•--E'�.i-',,^_ 1 -- Fes^--- -..' .. __._.
T7jt
11,'t'
F 'd
rim
0
i1r'r .m
NUllvklOdbp� N3fl233i�]
HUNI d3d U& k Ljz
'3dv,-1,J'YlJ N30Zk310 or.rJnvf n':

�. I -i •�.:.i r..a'.. � _ ! II I I`j i , , t .! i � '11 1�.. rlli .1.1 i.l' ' _-.' �I : '_ -I'---^---- � ...
:, �.-'���:i, r;; I•st x•r, ,l . •.r4 i;a a II"r 'i��''ll� 1' is Vj ti1j`j ,ti .`«.«! � :, `.+ .i' :I.�L. { I- ..I �_ - _ _
�{S
J• _...� W'!r :i I I �' { a. i I �' 1 I II r , I• ` 1S �I{ ',ri �, i ' I r,' 'Its "_�'_--`^' i
^�'.. i�il ':1 �;! I,:' i� ' � •i. ''i I�� I �I!� ;1, , i�iti rI r'i! ;.I: .- -I:. if _ I � I
-•- - -..I. tl i. , I 1 I, !•!-� r i«I ��` il, �' 1 ! I I! I I„ i I-'+-`•-j`• ---i
� • �;i�=,..... '.. 1 i'�.. � I i�}{ � � I' :ll� ii'1 ilit�1,'`' ^l.�l •I', ��' i' ' .�
�`-- -- - •r' li .��.. •:. � 'i. Illl ,ir �j i .I I i I
';'--- --�'-� '!-`}' ,•, •;: •i �ii .}i.,i it l'� `1i'j; I, ', •4 ',, ��'• rl �_.'� _ - ;. ' _�_ � f
S,.! - 1 . ,. - •;� I � ;l.l 1. ,.i � � . � � • i '1 ��. . � `� 1 . � . . -
:;' 't ' '"'�� ' !' '�I - - I;-)-t" "il - --{- - -may-_'^ .. Ham_^_ _._ i_ i .. .i- -- - •- �------t..
' l• . �II1 '? ;'I '' 'I' 11, IIII � ''}`51C Ilr i�l�l ; �i il'� ''; ��'� I' •i 1, ' t i •
c••�` i.�._� .� . ;Ir I 'yIL+Flf•� I+ T '��"-1�t: �wL. - 1 !_.. - ._ !
�1;'II,'i �I" ' .j. ,�• 41� r'T { � •'• I• I. -I. _.t......
�I1 . .a '7Ti44
47
IF
• — ,l '�.— i r I r:i l -i- - r��_w _..i_.:. ,„ — I .I 1 � I — ' I — _. {I1 -`T• }- � ' .�
_T , _ l _ i jF}Ft 1 I • 1 I. I 1 i T } I ! � � � I S i I
�i• •� :ti` '''• i;il '`I i' fi3� ,1 i,• 1 :l� I { ' I � �I � 7tI it` .' I �;• l •�..
it : ,1: �1 ; ii • + :�' ::: ,: ' ' ' j i , ' I} i ' «
�� _ .i• �� `t• :i .it I !` .,i '' 'i, ,i� '� i ,� ,i � �'' Jell � •["� I :', 'i I __!._ - --; -
-2
I -,-a 0
..r,H Ja— h:JNJE13HDe,X❑Z
Nt]11VtlRd di0 1V3'.]Z131fl !-ib�•,' ',rlV fl:l N30Z131O UZ,HUt

S�
m
LK
s
111M
t{
}1
It; ;� r
IT,
JITT;
,
14
rr
l�i,yE
in,
zoo
.I_._.{•
• �
!
r
�
-i-�
• ,
I
, . ,
ram--
�
Tit T
Ly
:J7,
�:�
--•!1i
''
1 I♦
ir�a
.1
4...
I;-ri
h
. I
•
•!,.
i11
,1If
�I,#
lrj�
�1
;r;
I{T;
:i�,`
�'
il:
'�;
i;;"
:r;
f!
1;4,
;�.;
'•li'
_'
ijl+-:
t
•r•
!:'F;I`I
•+
L.1�
.1.
i�•`
r.k
rl
.!!
II
:I I'
E; 1
0-f-a'.j
ill•
'II
77
•:•'I
;.�.
�`i.�T�
;; !
V • 11 NI 70YM
N QI1 YflRdil {]� N31 L1Z131f]
HDNI 8.-1d ❑d x u2.
r1311or1 HdVdE1 N39"Va C3Z-6OkU Y1F1

ii❑ e4OR•2O DIETZ13EN 43RAPH I+PPLR DIETZOEN CORPORATFON
"D X 213 PER imCH Mwnr ,.d u s
I n
0
I

NO 34(3P,20 DIETZGEN GPAP1i PAPER DIET2121EN CORPE)RATIMA
20 X 20 PER IWCI{ w►pt ,H u ■ ►
:I. '
4
•i
,_TM
� I
�.I1
J
'
�•
p:
y
I
.I:,
4
i.i[1:'
}�+.
.i '`-
Li
'�`
,Ii
.—
�i'S'
I f
�
I
I i—
, r�»
r
'I
i��,�,
I..�
.I:1 7.
{
a.: IIr — 1
1.
I,
T
il•i
r,l ';
.;.:_
•.,
'�t'
..
il.'_
•�_
I
i
�._-�._��_
I
�.i.
'
,�!
`'
;
_.:T.. ''
i 1,
Il i
I'�
I'
1,
,
Ill:
1,
'�,
11
I-
-
i
'�• �
1,1
[•t�
i:1,
.,•
��`�!.r�,
I!:i
,�
6,
�'�
,,
l l;
,
,'•
ls'
�
.;"
{
—
—
—
-�
r
I
I
,
'
T'
.--' {�..._--•
__ ... '_ ' _
i
� i
to
�r••-�-^'.I
I.
_ ""
'I
'I 4. !
'�'�'
�
.:
I ,
' ' i
'
�
J'. ;
i.Ji
•' ; '
-+�
_—
.�
... I w..
_ 7. . I . .- i..�-
.�..y
'
^•
.
17
,
fiii
...... 1.._ '�
,__r ..
II •• �' r
�
- .i .•- }-•_•-�--___
'•—
'1` '
��-
+:1.
��'
i ...1 '-.'r
!4r
-,�1,•`
'_.I b. '�_�
T'�'
i''i
�'''-
i+j+ r
i;i
iy i.
,
..
._�.ry'.��_
.. �--'
.�il, r'
Fi,
47
j';I
—_
•�
!
If•
•�'
I'
'
', I. i
141!
I"t''
1'
i7777
- _'
-
!
,.',
E
I it
;1 II ;,
Illf
llliLL
. F. i
k••-'
� 'i.,
:1.
'F-
^I' '[.
j,l ii i'
I: y. { c. :,. 'l:�
I�_
�{1
1{.I .�1
,
I''!
'I '
elrl
'71�
1•�i
'i
,
,ril
-�e-l�yi
',1
~'
J
1J,
1', 1 J 1
r• r7
'1
;I i.
`i`{! j-�,_
1
_Itiil�lt�.
''�
�
T
'
.i:
'
.1,
I,1;
114!
S
G�
05
�F

rl❑ InUR-2U DIETZGEN GRAI+I, 1•s1+E,;
2a s 7n Fco INum
DIETZOEN COMPORATION
Move /N U r
MET-91110
MR
rin
PA
5IF
wa
5f?

NAME: Freddie Halso
VOLUME = DEPTH I AREA OF TDP + AREA OF BOTTOM + 4 x AREA OF MID -SECTION I
6 27
VOLUME = DEPTH [ L 1 0 + L I W + 4 t L I 4 ]
6 27
VOLUME = 10.0 1 250.0 1 190.0 + 210.0 1 150.0 + 4 X 230.0 1 110.0 3
6 27
VOLUME = 10.0 I 235400 I
6 27
VOLUME = 392333 CU. FT. -
27
VOLUME = 14531 CU. YDS
51084 ft 388745 cu ft needed

UrdWd soli Post Office Box 277
Depobead of ronserason Kenansvi l l e, forth Carolina 28349
AWWsenfice 919-296-1958
April 21, 1986
Mr. Jimmy Sauls
C/O Murphy Farms, Inc.
PO Box 759
Rose Hi11, North Carolina 28458
Dear Mr. Sauls:
This is to inform you that I made a construction check of Freddie Halso's lagoon
on April 14 and April 77, 1986. The lagoon meets the design prepared for the
site; however, Mr. Halso had not seeded it as of this date.
When this portion is completed, we will be in a position to complete the
certification of the waste management system.
If you have questions or need additional information, please feel free to give
me a call.
Sincere y,
nneth R. Futreal
istrict Conservationist
cc: Freddie Halso
0
Tim Sod C-MamVe oe s«nc*
. is an *0&%V of V*
•

Nll f HIN dl1 UIL (LGLN li h'AF'1I I
LEI . 21) 1'LN mull
J3-
D'ErZUEN CORPORATION
ex
11HOINDID001
V1011m
IN
fill
UPI
oil
1111
.!
II
�I
g�
i
i�
5F
5f1
m
IJ�

NU -1 U114 21, UIL I 1.011-11 ONAI-11 1- , L N
;!I] r -III FkI1 1411III
r
s
I
��
y}il
�l
f
111
;��1
I
I�•
! I
!Ih
I
j
��
��;
4i►I
{, I
i�
I
}�I
:
'•I
l
�;,
ill
(
�'
'+��
�
I i
��
'�
;r
II
�II
{,�
1
'�j�
;{II
}It
;Iit
I. I
;!�'
!,
}1{�
.,j;
•}!
�I�!
;�
�4 �
1�
�`
I
} it
I
'j!�
�
I ii
I1
t•
II }�
�t
({
I `I
!i
i#
'�I
, I,
illy
iI•.
'I
►1�
s
,Il
I,
i
I
;�
I
I.I'
;'
� �
I �
�
,
j�I
:F
nl-;
_,.
;-
1�t4
1.Tt;
lI
I� I
i{'
I'!'
�'i
� !
� �i
i.
� !
��'I
I�I
il}
'•�
��II
I}7�
III
11�E
T"rt
f
,-r
III
UILIZULN Ck)NVUNATIQr4
Nm r�rrura,!„�n���I
s4

Producer: 6,4J.'e,
Location: 3 ► Y Lf'"r Rj'
C't'r e►i'44P"A' AJ G. �� I
Telephone: O r o) 18� H�99
Type Operation: +a
Number of Animals: (oGx>
(Design Capacity)
RECEIVED
WATER WAL ITY SECTION
UAN 2 8 1999
Non-Usch ge Permitting
The waste from your animal facility nmst be land applied at a specified rate to prevent
pollution of surface and/or groundwater. The plant nutrients in the animal waste should
be used to reduce the amount of commercial fertflizer required for the crops in We fields
where the waste is to be applied. This waste utilization plan uses nitrogen as the limiting
nutrient. Waste should be analyzed before each application cycle. Annual sod tests are
strongly encouraged so that all plant nutrients can be balanced for realistic yields of the
crop to be grown.
Several factors are important in implementing your waste utilization plan in order to
maximize the fertilizer value of the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply more nitrogen than the crop
can utilize. Soil types are important as they have different infiltration rates, leaching
potentials, cation exchange capacities, and available water holding capacities_ Normally
waste shall not be applied to land eroding at greater than 5 tons per acre per year. With
special precautions, waste may be applied to land eroding at up to 10 tons per acre per
year. Do not apply waste on saturated soils, when it is raining, or when the surface is
frozen. Either of these conditions may result in runoff to surface waters which is not
allowed under DEM regulations. Wind conditions should also be considered to avoid dri$
and downwind odor problems. To ma? mixe the value of nutrients for crop production
and to reduce the potential for pollution, the waste should be applied to a growing crop or
applied to bare ground not more than 30 days prior to planting. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. Acreage requirements should be based on the waste analysis
report from, your waste management facility. Attached you will find information on
proper sampling techniques, preparation., and transfer of waste samples to the lab for
analvsis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A
NCAC 21L0217 adopted by the Environmental Management Commission.

V .- w. fw N ,'".'.0 i
Xrry �� N � o� t �
Amount of Wane Produced Per Year(gallonr, tan, etch
40i>_ animals X !! aM'.) waste/aniIDaUyear=a,3�', zmC� waste/year.
Amount of Plant Available Nmogen (PAN) Produced Per Year
60o annmals X6.Llbs. PAN/anima /year = 39oa Ibs. PAN/year. (PAN from N. C. Tech
Guide Std. 633)
Applying the above amount of waste is a big job. You should plan time and have
appropriate equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on the crop to be grown
and surface application -
Table I: ACRES OWNED BY PRODUCER
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
# 'No. Type Per Ac. * Unflized Application
Total U 0 7 1_4393 I
* This N es from animal waste only. If nutrients from other sources such as commercial
fertilicer are applied, they must be accounted for. N must be based on realistic
expectation.
NOTE: The applicator is cautioned that P and .K maybe over applied while meeting the N
requirements. Beginning in 1996 the Coastal Zone Management tact will require farmers in
some eastern counties of North Carolina to have a nutrient management plan that addresses
all nutrients: This plan only addresses Nitrogem

Table Z: ACRES wrm AGREEmENT OR LONG TERM LEASE
(Agme=nt with adjacent landowner must be attached)
(Required *Wy if opemor does not own
adequate land [see Requhmd Specification 2j)
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
See footnote far Table].
Totals from above Tables
Acres Lbs. N
Utilized
Table I
Table 2
Total
Amount of N
Surplus o e
J6.9
393
Produced
ficit
3 ao
93
NOTE: The Waste Utilization Plan must contain provisions for periodic land
application of sludge at agronomic rates: The sludge will be nutrient rich and will
require precautionary measures to prevent over application of nutrients or other
elements.

See attached map showing the fields to be used for the utilization of waste water.
Application of Waste by Irrigation
Feld Sod Type Crop Application Application
No. Rate Amount k
F,
&-
.'a
. S
E d
IBTS TABLE is Nor NEom IF wAsm is NOT BEING APPLED BY IIMQA1ION. HOWEVER A SMI AR TAaIE WILL
BE NEEDED FOR DRY RIMER OR SLURRY.
Your fac gity is designed for ilf-2 ays of temporary storage and the temporary storage
must be removed on the average of once every- (, -MONTHS. In no bstanc should
the volume of waste being stored in your structure exceed Elevation
Call the local Natural Resources Conservation Service (formerly Soil Conservation
Service) or Soil and Water Conservation District office after you receive the waste
analysis report for assistance in determining the amount per acre to apply and the proper
application rate prior to applying the waste.
Narrative of operation:
— ,.a1.cL
A ✓mod armor,
s -a /

REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land
application. Any discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the producer either owns or has
an agreement for use of adequate land on which to property apply the.wastn Ifthe
producer does not own adequate land to properly dispose of waste, helshe shall
provide a copy of as agreement with a landowner who is within a reasonable
proximity, allowing hitaker the use of the land for waste application It is the
responsibility of the owner of the facility to secure an update of the Waste Utilization
Plan when there is a change in the operation, increase in the number of animals,
method of utifikwtion, or available land_ -%a-
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs fork
crop yields based on soil type, available moisture, historical data, climatic conditions,
and level of management, unless there are regulations that restrict the rate of
application for other nutrients '
4_ Animal waste shall be applied to land eroding Iess than 5 tons per acre per year_
Waste may be applied to land that is eroding at 5 or more tons, but less than 14 tons
per acre per year providing grass filter strips are installed where runoff leaves the field.
(See FOTG Standard 393 - Filter Strip).
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field
6. When animal waste is to be applied on acres subject to flooding, it will be soil
incorporated on conventionally tilled cropland. When applied to conservation tilled
drops or grassland, the waste may be broadcast provided the application does not
occur during a season prone to flooding. (See "Weather and Climate in North
Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
runoff does not occur offshe or to surface waters and in a method which does not
cause drift from the site during application. No ponding should occur in order to
control odor or flies.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen..

``' �"+ff 'Ys"�ax�^��7 �'S^^r�•� :ear «+r � � s�� �- ' ��. .f�.,...:.. :x�;;;...
REQUERM SPECIFICATIONS
(conE need)
9. Animal waste shall be applied on actively growing crops in such a manner that the
crop is not covered with waste to a depth that would inhibit growth. The potential for
salt damage from animal waste should also be considered
10. Waste nutrients shall not be applied in fall or winter for spring planted,crops on sods
with a high potential for leaching. Waste nutrient loading rates on these soils should
be held to a minimtuu and a suitable winter cover crop planted to take up released
nutrients. Waste shall not be applied more than 30 days prior to planting ofthe crop
or forages breaking dorarnzy-
11. Any new swine facility sited on or after October 1, 1995 shall comply with-O e
following: The outer perimeter of the land area onto which waste is applied from a
lagoon that is a component of a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or -river (other than an irrigation
ditch or canal. Animal waste other than swine waste from facilities sited on or after
October 1, 1995), shall not be applied closer than. 25 feet to perennial waters. (See
Standard 393 - Filter Strips).
12. Animal waste shalt not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and public right-of-
ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands
by a discharge or by over -spraying. Animal waste may be applied to prior converted
wetlands provided they have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a mazmer that causes no runoff or drift from the site.
16. Domestic and industrial waste from washdowa facilities, showers, toilers, sinks, etc.,
small not be discharged into the animal waste management system

...+. � ♦ c Sw s H t-. "" � E' �e 'x - .'�';' a r1 E s.<. .t�^r�..�:=> �...
REQUIRED SPECIFICATIONS
(continued)
18. if animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan' which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected on argplar
basis to prevent breakdowns, leaks, and spills. A regular maintenance checklist should
be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops for
direct human consumption. However, if animal waste is used on crops for direct
human consumption it should only be applied preplant with no further app4iVions of
animal waste during the crop season.
21. Highly visible markers "be installed to mark the top and bottom elevations ofthe
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall
be managed to maintain the liquid level between the markers. A marker will be
required to mark the maximum storage volume for waste storage ponds.
22. Waste shall be tested within 69 days ofutiliration and soil shall be tested at least
annually at crop sites where waste products are applied. Nitrogen shall be the rate -
determining element. Zmc and copper levels in the soils shall be monitored and
alternative crop sates shall be used when these metals approach excessive levels. pH
shall be adjusted for opti=lm crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry waste application records
shall be maintained for three (3) years. Waste application records for all other waste
shall be maintained for fve (5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina regtulations.

WASTE UTII.IMITON PLAN AGREE
Name of Form: l ,16 �o.rMS --
OwnerlManager Agreement
I (we) understand and wdl follow and implement the specification and the operation and
maintenance procedures established in the approved animal waste utlirafum plan for the
farm named above. I (we) ]mow that any expansion to the existing design capacity of the_
waste treatment and storage system or construcdon ofnew, facilities will require anew
certification to be submitted to the Division ofEnvironment Management (DEW) before
the new animals are stocked I (we) also understand that there must be no disohatge of
animal waste from this system to surface wasters of the state from a storm event less
severe than the 25-year, 24-hour storm. The approved play wiR be filed on -site at the
farm office and at the office of the local Sod and Water Conservation District and will be
available for review by DEM upon request.
Name of Facility Owner —
(Please print)
J
Signature: Date:
Name of Mans If different from owner):_�fOe_ _
Signature: 400�Date: 0 `d� r
Name of T cal Specialist: (Please pant) r e,.W
Afallatlon: M wr-hk" -Vi. r
Address (Agency): p2 p, Tex :10 — -.
Signature: _J=� en�, 1e _ Date: a V 9 7

Fxistirt, ) or New
Animal Waste Management Plan Certification
CFteaac n•ee or vrint d1 inrormacnon t111t tln<i nf)t rcuuire a siertature
ded - (Die2se circle one
General Information: AN 2
`a_ne of Farm:, %AAe1A ir.. ram_ -- Faciliiv No- 5
Owner(s) Name._ �&A,1 a. A-1Sn_ __-- Phone c 45g9
Z ' � uwf $
Mailing Address: 1 Lwr:l e-t� t �}C- ZSS !
Farm Lncariort: o t << County Farm is local dill:_� �1,�
Latitude . nd Lonzitude.-a 3-3 ! �_� y �S" Ince- razor:
Please a.tca-ca a cuov of a county road map with location idzatitied and descri� Mow (Be specific: road
names, directions. mt12t71}st- ax.)!
.� S. ►-++��5 ko c-1�
Oneration Descriotion:
T:•Pe Of swine NO. of .Anunalt Type orPouirn• No. of.-knitnals Tye of C cle VO. Of .lninlals
Wean to _gale* 7j Liver Lf D-�r
j -c_der to+ sntsh :j Pullets :1 lee:
Zi arrow to Wean
to .der &Q2
0 rz-ovf to Finish Orlier TLpr of rivesrcc.1%: vunr nr o.iAi iuxls:
Gists
_. n oa_,
it crrcir. s Cptrmion CSnlr . ' •. - . - � - - -
?rz_Sores Drn- t G:Qac-r:- Addiri7ncri•DeyiQy--C!tawc. 701:11
Ac_zage .-variable for �DOHCZUOM 1A1Reauired Acnm,2e:___ !�9%
Numbef of Lz2oons 1 Storage Pcnds : I Tocal Capac:irr: Cubic Feet ([t=1
Are suos;L:_ce drains present on dt: fart[: YFS or Q (please circle one)
If VES: are subsurface drains present in the area of the LAGOON er SPRAY FIELD (please c-.-c:: onet
art Y, In T, wsl tl f��siTI TYYww,sYafssal�Y��Mf!}ts}ay,Yia�Yarr�r��a �sara�aa as as a�a,ta[ataa s�a�aaRR �awf�wAwlt swt, sl ilHMrl r4 F+�Mri
Owner J tlanaaer Agreement
I (-et vcnf•-r [liar all the• above lnformauoa is correct and evill be updated upon ehangin_=. I {s„ understand the operaron
and maintenance procedures established in the approved animal waste mana;emeni plan for tce :ann maned above and - Hl
impla.mcac these procedures. I (wet snow that any expansion co the existing desisn cacudty of the caste utatment 3-id
storage SvStem or construction of re%v facilities will require a new eeruticauon to be subatitted to the Division of
are stocked. I (�C) understand t :[ pdC�37�C Ufeavironrncntal Manzeemcnt bctore tic new aumzls
ani:n: 1 waste from thr storas?t or appticauun system to surc3ce Lvare.-s of the State eidit: dirttiv through a than -[Wade
conve,'anct- or from a storm event. less severe rban the 25-year- 2—, hour storm and the .crust not be run-off from the
acplic_t:on of animal waste, I (tive) undtrstand tbac run-off of pollutants from lounging and heatw use areas must be
minimized using techuic_l s dards developed by the Natural Resoure_s Conse adon 3ernitx. The acoroved plan will be
tiles! at the farm and at the of Cc Of the local Soil and Water Conservadon District. I (Re) L-iow that any Modification
must. be approved by a techarcal specialist and submitted to the Soil and Water CDnse^•adon District prior to
imple :ie:iLl- ion. A change in laode,-Rership requires wTiaen nodfication to DEM or a ne- cz-rtincauon (if the approved
pe: n is ciastiS.Fed) within 60 days of a ude transfer.
tiarne of Land Owner _j tCl�old� - Lke:,
Si -nature: L��e�e.tr!tCitB Date: 2
Name of Man eit• &4=: ectf
Si-nature: r
Date: 4ZIZ
-
.a«-C -- -kuguat 1. a15i7 1

nujjKQP ^
Technical Specialist Certification
I. ks a technical specialist dtsignared by the _North Carolina Soil and Water Conser%-ation Commission pursuant to 1; A
NCAC 6F .0005. I certifv that the animal waste management system For the farm named above has an animal waste
management plan that meets or exceeds standrrds and speCiFcatiOns of the Division of F-m mnniental Management
(DE 5 as specified in ISA i`+CAC 2H.0217 and the USDA -natural Resources Consem-stion Service UNRCS) anchor the
North Carolina Soil and Water Conservation Commission pursuant to 15A NCAC 3H.0117 and 13A NC.-kC 6F .0001_
.0005- The following elements are included in the plan as applicable. While each category designates a technical specialist
who may sign each certitcacion (SD. S1, WUP, RC, fl, the technical specialist should only e-tify parts for which they art
technically competent.
If Certification of Design
-k) Collection—SStoraze. Treatment Svstern
Check- Me aapropriare bar
Z✓Exi -line facilkv_wichtmc revotic (SD or WL'P)
Storaec volume is adequate for operation cap-acity: storage cap bility consistent Midi waste ntilindon
raquirements.
;l New. expanded or re:roRued facility (SD)
animal vvaste storage and ueatment structures. such as but not limited to collection systems. Lagoons and ponds.
have been designed to greet or exceed the minimum standards and spec-ifi4aatxts.
Name of Technical Specialist (PIease Print):
Af:Cd rion__ M..r •� s Date Work Concicmd: la
Address (Agency):_ P.D. 7�9 `�se� ++f•!f PJZ. Z851.�8 -- -Phone \o.:9ro 41"-622!1
B) Land Avolication Site (WUP)
The plan provides for minimum separations (buffers); adequate amount of land for waste utilization; chosen crop is
suimble for waste a=a?emenc: hydraulic and nutrient loading rates.
Name of Technical Specialist (Please Print):
Af iliadovl _ (`OFF Date Work Completed- la 4
Address (Agency): P.P. ffM 7jr,9ea &= ,4I,'11.A1•4• S19 Phone 110�9-6w39
S i enai:ure :
C) RunoFf Controls from Exterior Lots
Check rice gvprapdafe box
Facility without exterior lots (SD or WliP or RC)
This fac-itity does not contain anv exterior lots.
rl Facility cvirh exterior lots (RC)
Nlechods to minimize the run off of pollutaacs from lounging and heavy use areas have been designed in
accordance with technical standards developed by ti"RCS.
Name of Technical Specialist (Please Print):
rct'tiliation_ Date Wort: Completed:
Address (Agency): Phone No.:
Si_znatura: Dam-
a«-C -- AU;
u3-t 1, 1991

111. Certification of Installation
A) Collection. rorage. Treatment in tallatfon
New. e:cnande-d or y rotitted facility (SO
Animal wa;ta storage and treaunent structures. such as but nor limited to lagoons and ponds. have been installed
in accordance uiift the approved plan to meet or exceed the mimmum standsnic zeal sptcificadors.
tj A For existing facilities without retrofits, no certifc-afion is necessary.
Name of Technical Specialist (Please Print):
Affiliation Date Work CUti)E)leted:
Address (Agency): Phone \o_:
Signature: Data:
B) Land application Site (WUP)
ChCCti [ire ctnproprtarx bOr
rd The cropping system is in place on all land as specified in the anime! %va;te manazemem plan.
Z.l Conditional Approval: all required land as specified in the plan is cleYred for planting: the cropping system
as specified in the waste uulizadon plan has nor been established and the o,61-aer Ills conttnitted to establish the
vegecation as scerlied in the plan by ---�_— _A (monthldavh•--:2-,): the proposed cover Cron is
appropriate for compliant, with tat wasteurilizatlon plats.
Also check this box if anrooriace
it (he CMftn s Syge:n ;c !rrwr trrdr in the_ n1irt ran rtnr. hr �srlhlishcd on newiv cleared lud within 30 dates
of this ceruf1c=n. the owner has eommined to establin. an interim =9 for e=ion control:
Maine of Technical Specialist (please Print): cn- SY
Affiliation Ml✓l~ _Date Work Cori ale cad:
?address (Agency): PA �rW 7n'l
Signature: S� Date:IJ11TA 7
This following signature block is only to be used when the box for conditional approval irk III. B
above has been checked.
I (-0 Certify that I (-c) bave corn.^ —cd to esubliSll the ==pin_ sys:ern as SpeCifted in my (our) ••ate utilttarion flan.
and if apprbpriate to establish the interim crop for erosion control, and --ill submit w DE I a verification of completion
from a Technical Specialist MU''sin [: calendar days following the date specified in the conditional ce:tilic-Icion. I (we)
realize that failure to submit this cenfwation is a violation of the waste management plan acid will subject me (us) to an
enforce,tent action (Mm DEM.
Name of Land Owne
Si-nature: Date:
Name of Manager (if different from owner):
Signature- Date*
ANVC -- Aucust 1. I997

D). Annlication and Handling Equipment
Check [he uppropnare box
e '5twa waist nVolicatinn eoL;ir!ms:n[ (tiS UP or p
lel Ex i5rjn� nr c1randing, �-'Cilifv w'id,�
Animal waste app[tcauon equipment sptctried in the plan has been either field c4biatcd or eyaluatcd in
accordance with existing desien charts and tables and is able to apply waste as oectsmry to accommodate the
waste management plan: {extsdng applicaeion tquipmeac car► eo�er the area required by the plats at rates not to
esc..d either the specified hydraulic or nutrient loading ekes. a schedule for tutting of applications haS been
established: required buffets can be maintained and calibration and adjustment guidance are contained as part of
the plan).
-t i s xc a ore -tic 'no FaciliKy wi e-c is ring-,,IstC o li 'on to Mipmem for %griv Dtlation (I)
Animal %vaste application equipment specified in rbe p[.an has been designed to apply caste as accessary to
accommodate the waste management plan: (proposed application equipment t:'ut cover the area required by the
plan at rates not to escetd either the specified hvdraulic or nutrient loading rarer; a schedule for timing of
xoplicadons has been established: required buffers can be maintained. calibmtion and adjustment guidance are
conmined as part of the plan).
„! \ztiv ecrinded, or eriann? flciliF�a_ %vie otu tcittin�an. 4te, anvlic:atinn estuirmem Air land tnmiding not using
sr. nv it g-anon (W ? or b
Antntai Waste aoplic:don equipment specified in the plan has been selettea co apply u-asce as accessary to
accommodate the waste management plan: (proposed application equipment c--n corer the area required by the
plan at rates not to eccttd either the specified hydraulic or nutrient loading tales: a schedule for timing of
applications bas been established: required buffers can be maintained: calibr_dun and adjustment guidance are
contained as part of the plan).
Name of Technical Specialist (Please Princ):
A�friii«ior �F - - -- -- Date War Cariple�Pd: 3 `
Address (Agency): P.o, 36x W-el ease--ht► L AU- aB�,+s8 _P one Via.:gioaSy-6y39
Sian a f_re: Date: 1.31 z
E) Odor Control. Insect Control. Mor-talitv_ManaQetnent and Ememencv Action Plan (5D.
Si. W-UP. RC or I)
fat waste management Blan for this facility includes a Waste Management Odor Control Cheddist. an Insect
Control Checklist. a L%•(or-,Wicv Nr(anazetnent Checklist and an Emcrgenev Action ?:an- Sources of both odors and
insects have bete evaluated with respect to this site and Best Management Pr_ct:z:=s to Niinintize Odors and Best
Management Prtedces to Control Insects have been selected and included in the waste seta tancrient plan. Both the
`[orWity `[anagetneat Plan and the Emergency Action Plan are complete and can be implemented by this facility.
Name of Technical Specialist (Plisse Print):
AfftUu ion Date Wart; Cutnple,.ed:
Address (AQency): Phone tio_:
S i_na_t:.ire Dve:
F) Nvr-irren Votice_of New or Expandin`S«7ne Farm
The following si-nature block is only to be used for new or expanding swine farms that b ,in construction after dune
3I, 1996. If the facility was built before June 21. 1996, when +vas it constructed or last
expanded
I (eve) de±-sfy that 1 (we) have ammpced to contact by ctrtfied mail all adjoinins property owam and aA progeny owners
who o6-n property located across a public road, street or hisbwav from this new or expanuiag sine farm. The notice Was
in compliance with the requirements of :vCGS 106-303. A Copy of the notice and a fist of the property ot�atrs notified is
attache• i.
Name of Land Owner:
Signature: ` Date:
game of ivlana;er (if different from owner):
Signature:
A%VC Iyy7

C) Runoff Controls frorn Exterior Lots (RC)
Facility %vith ester fir lots
tt�chpcli to minimize die nin off of pollutants from lounging and heavy use Areas ha_t t-era installed as speci{ied
1� in Ole clan.[It For facilities witlroitt exterior Ives, no cerriftcation is necessary.
Narne of Technical Specialist (Please Print):
Affiliation Data Work Comole:ed.
Address (Agency): Phone No.:
Signature: Date:
D) Anolication and Handlinz Eauioment Installation (NVL-T or I)
CheCk rite a ropnare Nock
xnimal waste applicadoa and handling equipment specified in the plan ii on iite and ready for use:
calibration and adJustment materials has t been provided to tlit owners and are contained as part of the plan_
_I minimal waste application and handling equipment specified in die plan has not beta installed but the owner
has Proposed leasine or tbi.rd party application and has providi:d a signed evatracc equipment speci led in
the contract agrees with the requirements of dit place: required buffers can be maintained: calibration and
adjustment saidinc` have beta provided to the owners and = contained as vast of the plan_
Conditional approval: Animal waste application and handling equipainu specified in the plan has
been purchased and will be on site and installed by (montJdaylyear); there is adequate
storage to hufd the waste until the equipment is installed and until the watt can be Land applied in
accordance v. ,u Lne cmYping sysmE:: contained in the plan: and calibrauca and adjustment guidance have
been provided to tae owners and ate contained as pant of the plan.
Name of Technical Specialist (Pleze Print): E
filiation Date Work Comol.I—ad:
Address (Agency):, >a, Sox 7S�i A'I I . A). C. -42M Phone `o.:14o J89 6 3�
Sim sanire. Dare:
The foilo%lin- signature block is only to be used when, the box for conditional approval in IIf D
above has been checked.
I (we) et��v'- that i (we) have committed to purchase the animal waste application zeal handling equipment as
sOecifted in My (our) waste management plan and will submit to DEM a verificarion of deUvery and installation
fiom a Te c, .:iLa! Spedalist wid-tin I5 calendar da ,s following ttie date spedded in dhe conditioraI crafUcation- I
(we) realize that failure to submit this verinc-adon is a Violation of the waste management plan and will subject rnt
(us) to ad enioriwtnent acdon hurt DENt, r
Name of Land Owner:
Signacure: _ Date: r
-Narne of Manager (if different from owner):
Signature:
Date:
E) 4dor Control, Tnsect Control and Mortality Mana^ernent. (SD.SI. WT'P. RC or T)
�f etiicds to control odors and insects as specified in the plan have been install&,! acid at"e" op�rivariai. Tri:
tnotizlity manammem system as specified in the Plan has also been installed and is operational.
Narne of Technical Specialist (Please Print).,'Y�(t
A ftliado �yn s(}i -' l � i12 ( S Date NVork Compteted: ! Z 1 o a
?address (?. acy): 'I r- Z 3w Phone `ro.:�la ati f�O
S t y rt:s tt1 C. Dale:
7
AWC -- AU; —0 1, 1997

1
Please return the completed form to the Division of Water Quality at the folio-MnI address;
Department of Environment, Health, and Natural Resources
Division Of Water Quality
Water Quality Section, Compliance Group
P.O. Box 29535
Raleigh, NC 27626-0535
Please also remember to submit a copy of this form along with the complete :animal Waste
Management Plan to the local Soil and Water Conservation District Office and to keep a copy
in your files with your Animal Waste Management Plan.
ANVC -- august I. 1997 6

6.►r, r-A r,"^s
REt; 2 1 V E D
WATER QUALITY SECTION
ANUN aL WASIMAT R, LAND AIC-LICATIOiY 5MEDY1 PL 2 8 1999
L_-
1. Waste Utilization Plan
✓ Operator has acceptable waste utilization plan
Non-Disch_-jqe permit6119-1
✓ Planned irrigation system is compatible with type of waste storage facility, soils, crops
and putrtping schedule shown in the waste utilization plan
2. Field Specifications (Use USDA-y-RCS Table I. or. Similar Table)
Legible FSA photo copies and county tax reaps of effluent disposal field'"
✓ Legible soil survey map of effluent disposal fields
✓ FSA Field numbers shown (Show FSA tract number when there is more than one tract
,involved)
✓ LVlaximum useable acreage of each field shown excluding bu&r or restricted irrigation
areas. The designer will decide usable irrigation area of each field.
Soil types of each field
Average slope of each field
Crops to receive animal waste are shown for each field
Recommended maximum average precipitation rate in each field (where there is. more
than one one soil/crop combination that results in a different recommended precipitation rate,
show the recommended maximum average precipitation rate for each combination)
v/Aecommcnded maximum application amount per irrigation cycle in each field (where
there is more than one soil/crop combination that results in a different recommended
application amount. indicate the recommended maximum application amount for each
combination)
July 23, 1997

3. Working Map or Sketch
► Legible o scale map or sketch with north arrow. Scale should not be greater than I "` =
200' :r-e.rxl a►.ar d -s�..s ,'s .W+ pr���. ! _ _ .-scj .: J'= 3 3oJ
-`Ditc nnial strew, wetland areas, and other bodies of water are identified along
with the size of each. ,
Surrounding water wells are located
Surrounding dwellings, schools, hospitals and other important structure locations are
shown "►ewe- etr-e, none ,a. At— ••�•
✓ Highway right-of-way locations are indicated
✓ Lo lion of farm roads, fences and other obstructions are shown to scale on reap
Critical property boundaries are shown -Prp'� ^Y
Location of waste storage facility and buildings are shown
✓ Critical elevations that are used in total dynaMic bead computations are shown
A'..5 !n!la.0 .
✓ Location of irrigation mains and laterals, sprinkler or gun hydrants, thrust blocks, etc. are
shown with the design spacing of hydrants and pipelines recorded on the, map or sketch.
This will be accomplished by the irrigation systems designer.
4. Irrigation Design Parameters (Use USDA-NRCS Irrigation Design Parameter
Worksheets or Similar Worksheets)
A. Traveling Gun Parameters (USDA -MRCS Table 2 or Other)
✓ Type of speed compensation (USDA -MRCS Table 4 or Other)
Design travel speed for each pull
Design precipitation rate for each pull
Design application amount shown for each travel speed
Effective width (lane spacing) and effective length for each pull
✓ Operating pressure at the reel and the gun for each pull
2 July 23, 1997

Nozzle diameter in inches, indicate type of nozzle
`Wetted diameter at specified operating pressure
Arc pattern for each pull
-"--'Hose length and inside diameter
—"�' Make, model and type of traveler and gun with manufacturer specifications
included
�Compuradons of acres receiving uniform coverage
y Specif cations on hydrant type and construction
f B. Solid Set/Permanent Sprinkler or Gun Parameters (USDA -MRCS Table 3 or
other)
Design hydrant or sprinkler spacing and pipeline spacing
Operating pressure at sprinklers or guns
Nozzle diameter in inches. indicate type of nozzle for gun sprinkler
Wetted diameter of sprinkler or gun and operating pressure
Arc pattern and location of partial circle sprinklers or gums
Specification on method of connection of the sprinkler or gun to the lateral line to
include materials required and method of connection to the lateral line
Design precipitation rate for full and partial circle sprinklers or guns
Design operating time for full and partial circle sprinklers or gums
Computations of acreage receiving uniform coverage
Make, model and type of sprinkler or gun is shown with manufacturer
specifications
3 July 23, 1997

NO C. Parameters of Other Irrigation System Type:
Design operating pressure at the sprinklers/ gun
Desi-en precipitation rate
Travel speed for system
Design application amount for each travel speed
Computations of acreage receiving uniform coverage
Make, model and type of equipment along with manufacturer's literature
D. ai Clines
/Size, type and pressure rating of pipelines shown on the working map or sketch
✓ Computations for spacing of hydrants and lines
Computations of velocity in main lines from equation's on pipe chart
✓ Computations to verify the adequacy of the pressure rating of all pipelines and
fittinss
✓ Loc arions of check valves, air/vac relief valves and pressure relief valves
- T' r t block locations and computations of the required size (USDA -MRCS Table
S or other)
Pipeline installation specifications including depth of coverage, type of
connection and method of backfill and compaction
5. Pump and Power Drive Requirements
✓ :s6ta6c
'c discharge head computations
suction lift
nkler or gun discharge pressure head
Computations for friction lass in the pipeline along the critical design path
4 July ? _, 1997

✓� Computations for minor losses through elbows. valves, and other fittings (it is generally
accep le to use 5 ercent of the total headloss from the previous losses computed)
"sed to%
A summary of the total dynamic head (TDH) of the system
Computations of the required brake horsepower
L- Computations of the required engine horsepower
Computations of the Net Positive Suction Head Available (NPSHA). Insure that NPSHA
is greater than NPSHR
Net Positive Suction Head Required (NPSHR) at operating conditions from pump curve
✓ Manufacwrer's specifications and performance curves for the irrigation pump and power
drive
'-- Size and type of suction pipe and strainer and method of connect in suction pipe to
suction inlet *• 6W, d., jy .Jr.►!.� .►-,��--
6. Operation, Maintenance and Calibration (USDA -.MRCS Worksbeet Page 6 or
Other)
pecific operating procedures for the operator
t/ System maintenance recommendations
✓ Calibration procedures (recommend that materials developed by Dr. Evans and Dr.
Barker be included with the design)
-ft..
7. Certification
- ✓ Design is signed and dated by an Irrigation Technical Specialist (USDA-NRCS
Worksheet Page 5 and Other) or Professional'Engineer depending on legal requirement
8. Jnstallation
Insure that spacing of sprinklers, guns or hydrants are according to design specifications
Insure that depth of pipe placement meets or exceeds specifications
Insure that placement and size of all thrust blocks meets or exceed specifications
5 July 23, 1997

Insure that bacl f ll over pipe does not contain large rocks. stones. or other foreign matter
and that placement and compaction has been properly accomplished
Operate all zones of the system and insure that there are no leaks. that all sprinklers, guns
or other application devices and mechanical equipment operate as specified to include
travel speed, depth of application and that specifications are met or exceeded
— - ---- Consider use of a permanent post (marker) is located _where the sprinkler cart begins a
travel lane -
Insure that all airfvacuum relief valves and pressure relief valves are properly located and
operative -
Insure that gate valves, ball valves, butterfly valves, check valves and pressure gages are
in place and properly operating. Pressure gages should be glycerin filled and located at
the pump, on the sprinkler for a traveler and near the end of the most distance spdr lder
Note on the design drawing where modifications may have been made in pipe or sprinkler
location
Insure that the pump meets or exceeds TDH and gpm specifications
Note where changes may have been made in specified product
During the actual installation, check behind the contractor to insure that substandard
installation techniques are not being used
9. General
Irrmgauon specifications should include a pumping schedule for each field giving the
number of pumping hours required to meet the crop PAN requirements. This schedule
should indicate the gallons or acre -inches to be applied per acre, the amount of each
application and the total number of applications. The schedule should also give some ,
idea of the timing of the ap 'cations. -M,s ;s red.�d.�,.-t- .,,..at w.: ( he---e,0`41S
eti .,1ks� �.. .,.A r..r.rr..:�t 1-0 s, x,
The Plan should discuss application record keeping, need for sampre afalysis, need for
soil sampling and length of time to maintain records
ZThe Plan should mention the need for an Emergency Action Plan (EAP). The Plan is the
responsibility of the grower.
The Plan should include information on annual system evaluation
6 July 1997

✓The Plan should discuss soil type(s), soil(s) maximum infiltration rate. coral PAIN
generation to include sludge, loading rate(s) based on Realistic Yield Expectations
(RYE), and maximum Ioading rates both during summer months and wetter winter
months .--- i,%J k P.
An optional item of the Plan is a bill of materials. Normally this is supplied by the
insmIler and not required by the designer. The designer should specify pipe and fittings
-- - pressure ratings or schedule, pipe size, valve sues, yalye pressure raring and minimum
specifications of all equipment and specialty items
7 July 23, 1997

1W.414112vidsh
IRRIGATION SYSTEM DESIGN PARAMETERS
J,ando►rner/OparatorName: Mi w &v-1 ! County: tip,%
Address: 3f�{ le.news l;�•+�ar �, l �Z
A.J, G. -S S" pate: , . 1Z-; !z
I ] .El - Held Specifications
i
t See attached map
2Total field acreage minus required buffer areas
3Refer to N. C. Irrigation Guide, Field Office Teeluiical Guide, Section Il G. Amival application must not exceed the agronomic rates for the soil and crop used.
MRCS. NC
RUNE, 1996

i
TABLE 2 - Traveling Irrigation Gun Settings,
EXHMrr D-2
hiskc, Model and Type of Equipment:
�.,n -
F.� �r r�
,j/g431,
s.� �,ew
dgre.J r-�Rld
40 g
Pietd Nol
and
Nat
Travel
Speed
(RJmin)
Application
Rat&
inft
TRAVEL LANE
Eircctive Qf'E'cctive
Width (fl) Length R
Wetted
Diameter
fees
Norrla
Diameter
(inches)
EQUII'MEN'r SETTINGS
OperatarS operalmg
Pressura Pressure
Gun (psi) Reel (psi)
Arc
PatlinO
Conks u
3.
�
� b �
��
. $►� r'
Q
t»°
� q 3
.mac ��
la
S
. Sra r,
boo'
a s c�
Se)
f'-
$
°I
goo,
,`do werw9 137
D
Sq
o 1
Y,(,
+) r,or
4T
S
o"
4rl?
i,' �o�
16.9 �-a
r /
+�,..
til
ue.�
f4S
1II
-
.+
Ad rot
c • .
i[
.. •-� Y� �.v.i r.. Slke 'r
-i wt
� n r r.
.fc r
� .
<��..
.Se --
.Mi'_!.
i
l See attached mull,
'Shaw SCP=te eltlrieS far CaC11 hydrant locutiCtl in each 50d.
3Ust the (ollowit+g abbreviations for various arc patterns, 1: (full circle),'rQ (three quarters), TY (two thirds). it (half circle), T (onc d6id), Q (one quarter)
May also use degrees of as c.
MRCS, NC
JUNE. 1996

TABLE 3 - Solid Set Irrigation Gun Settings
Make, Model and Type of Equipment:
OPERATING PARAMETERS
Fl-ld Not Wettcd Hydrant Spacing (it) Application Noazle operuting operating
Id Number of Dlnmeler Atang Between Rat@ Diameter Pressure Time
Line Nat Hydrants feet PI -line Pipelines Inlhr nthcs Gil si Hydrant r Comments
l
!See attached map.
2Show separate entries for each pipeline with hydrants in each Geld.
P—XHMrT D-3
MRCS, NC
AJNE, 1996

BX1Mfr D-4
TABLE 4 - Irrigatlon System Spedrications
Traveling
Irrigation Curl
Solld Sot
Irrigation
Fiow Rate of Sprinkler (gpm) Ito
perating Pressure at Putap (psi) lGq
Design Precipitation Rate (Infhr) pq .
Hose Length (feet) $
XXXXXJCXX
Type of Speed Compensation !
XXXXXXXX
Pump Type (PTO, Engine, Electric)
Pump Power Rcciisiremcnt (lip)
TABLE 5 - Thrust Block Specificationst
a thrust 6
CLOCATION I TIAUEAT BLOCK I
900 Bend
Dead End
MA-N= Field Office Technical Guide, Section IV, Practice Code 430-DD,

EXK BIT D-5
IRRIGATIONS TEM DESIGNER - - --
Namot . C'?of� ecf'_
Comp any. S
Address: Dose.. 4% sg
Phone; no) V4- ("ag Lrf *Sgj
REQUIRED DOCUMENTATION
The following details of design and materials must accompany all tniga►ion designs
1 A scale drawing of the proposed irrigation system which includes hydrant locations, travel lanes, pipchne routes, tlu-ust block locations and buffer areas where applicable.
2 Assumptions and computations for determining tolal dynamic head and horsepower requirements.
3. Computations used to determine all mainline and lateral pipe sizes.
4. Sources and/or calculations used for detenniuing application rates.
5, Cornputalions used to detenmine ilia size ordintst blacks and illustrations of all timist block caufiguratians required in the. system.
b. Manufacturer's specifications for the irrigation pump, traveler And sprinkler(s)
7. Manufacturer's specifications for ilia irrigation pipe nrul/ur USDA-NRCS standard Far Irrigation Water Conveyance,
N.C. Field Office Teclunical Guide, Section IV, Practice Code 430-DI).
g. The information required by this fonn are the utinlmurn requirements It is the responsibility of the designer to consider all relevant factors at a particular sits and address them as
appropriate.
9. Irrigation pipes should not be installed in lagoon or storage pond embanlunents without the approval of the designer.
NOTE: A bufrcr strip !� feet wide or wider must be maintained between the limits of the irrigation system and all perennial
streams and surface waters per NC Statutes
MRCS, NC
niNB, 1996

Narrative of irrigation System Operation
]escribe the operation of the sysicin in the space provided below or on a �milar sleet most convinitnt to the dasignedsuspplier.
Aciude procedures such as start-up, shut -down, winterization and regular maintenance of all equipment.

NARRATIVE OF IRRIGATION DESIGN AND OPERATION
FOR
GABRIEL FARM
DESIGN OVERVIEW
This irrigation system is designed with four inch, Class 200 PVC pipe and schedule 80
fittings The system is designed to accommodate the flow velocities, flow rates and the
pressure requirements associated with the AgRain E-25 Traveller Air vents and thrust
blocks are to be installed as indicated on the drawings and sized according to the design
Air vents will consist of using a 4"x4"x2" Schedule 80 tee and 2" Schedule 80 pipe,
Schedule 80 fittings(elbow and MIP adapter) with an AV 150 The thrust block areas have
been calculated and are listed on Exhibit D-4 in the plan The design of this system
requires the use of a 812" ring nozzle Each pull has a specific arc setting and travel
speed which must be used to achieve the desired application This information is given in
detail 4on page 2 of this design A detail of the hydrant design is also included and specifies
the type and size of fittings All pipe shall be installed with a minimum of 30" of cover and
shall be backfilled in no less than three passes, leaving enough soil material above original
grade to allow for settling
SYSTEM START-1L1P AND OPERATION
When setting up the reel, make sure it is level and the stabilizer legs are down and secured
Engage the brake, then disengage the transmission Pull out hose at a sped not to exceed
3 mph Engage transmission before disengaging the brake Prime the pump and start
engine at idle. Operate engine in a manner not to exceed 50 psi until a solid stream of
water is exiting the gun, air is out of line and pressure is slowly building on the gauge
Increase rpm's slowly until desired pressure is achieved Set all "Murphy" safety switches
to insure immediate shutdown of system if a problem occurs Also, set the timer to shut
off pumpat the time a run will be completed -- but, make it a practice to idle the system
down instead of relying on the safety timer Check all safety switches on the reel after
each start-up to insure proper operation. Read and review the AgRain operators manual
for additional details on start-up procedures Grower should walk the entire pipeline
periodically to check for leaks or potential problems
Records of irrigation events shall be maintained in accordance with the OIC certification
training Nitrogen applications are not to exceed the recommended loading rates for each
crop as specified in the Nutrient Utilization Plan All records shall be maintained on the
farm for a period of five years
VONTERIZATION
Disconnect both ends of all flexible hoses at the pump and the traveller Remove drain
plug from gun cart and pull out hose at least half way to purge enough water to protect
from freezing Wind hose back onto reel and replace drain plug

£ N -
l all
�c cot
- - - - - - - - - - -- - -- - - ----- ---- - - - -- - - - __-_ - - - ---- - ��/ -cam-- ---- -- -- - - -___._ _ --_

f' 404901
Sg i Ub "• (�F�f �hc�Sb r. r-"i/ % ovb ;
1
le
E•!
S
OX 1
z:t;lk VI'r ; 47L '51 �r" 1 l l � b = '"I d f"r-$ * l v'laL
7. c_ _ f — 1
r

- 7f -- - L - �6•� --
OWv
f
�f,G.�a •� �1Y $ �_ �y/„,wLg.C'b b - --_- -
f
5WIr rah- Qoa'o6► �� r p � �ra �fy�ar X f��. �Q� _ - -__ - - -

�t't '�'�' �:` ,;5, � � •Fi � Off' '�
731
bo
t.
,r; ••r�.l•��ty�t4�i.s• 'y�•�it�,. K �� '�r r
r +-, ''�i: o- •fir �s '' j•, r w'`ii�� V ' : Y
•� �'.r r � f • :J4j'4►,• rL+ i • t ♦ � . U� ;� M' . �+` � 4, 1 ��,d�i'I�t ' ��` ,''t S 1 •�Y,�yt�'1. ;� � •�, 1 •` � � t ' ��.� � ' .
^. r! .'�: F. '� � �i• Y rK' ��L,��'-]• :Y+� : i}• `� Lei."•• irk• :f� `'S � l' }
�.r� � ~•i S. rf � ,.$ s.r 1 T�}.W � j 15 r F•tt � �� r � � _ t:+ �' r �,: lr .+ i i
ys"�'�+'-•� �*' y t5r4''tiF-4�J � _'�'f •l. .�'`' iy . 4 r � •+� }• � +� , t
h ,• G'L w •r `. 1' ^ ��� s r rYt y� t ; 1 �' y } J'
1p
uAr
O �.' � •s`�.,. a +A. ` !.' j{ F r � 1•,-t'� J- � •d r + S
'1 r � 1 r, i•�. r� t , 1 .d s ,'ice' .1 J� "�r+ y �
lit
l sr c • , J. G � 1 � 7l • ' �yy� ��. ' e
+ / � , t �r. +y' I. . � Q' is '• +tM � � ` � #�. t .� +�Y 4.� � i � �� J
� if -��1.' Nl�j •, 1+ a 1+ � , �� � � ����,,�,++���d,� '� ,,,5
I

T •,�►w .•hr1�
L� r
l` r! tl �•,A'4i _ `r'tii� i:= - •..r..1. +�'` ., re 'j J �T !r
`•'' It � � �i ,M� �1
r 1'�llr } y�J[ Ya� � f rtl �. 1.� ,J '� `� •
?µ
Y

.0) I
Op lop •
It.
a 7121

111V *
I -rt Pn*—VoJ
T*7� 1--,Jl

�jr-
iGdilNfii3fifiS
�,
pp yr�� rryr by;
��...•!-..r. W
11N�ONSIN
:..
O"
a84Rifl�475Z
0-4
six
ransit
HP
COMA
0.
�y
ell
- �r '^ ., wiTni'� �q i .r' .•i7RLr•1.lgt•SC+t �•a. - - � : �`.,.:..
o A0. w
'll
Mill :> ��r'�
'14 to
WAS MUMS
;;QQ ��QQ v�• ,!� YYr1�rS ri��
�n iN�iQFSn�if � o d+�f3�:•��i � ��li6alil��� .s ��0 7d�n�m2Ra�S � S �3�����
r�ow0. � �+�� �,!• �#� aid rry•:�1 t
as
8 . �N. 4 WHOM
its
�w
�.:Q i:a.7iin�SbS a w
l Id
..
Sa•` �k�MUM`�� Ag
om � Q z f �•�p �_ . $.-..��',', �� •i 0.'��w��A7S H Hari �-
� `�
gig k a a,
� F
mum s o MOM
� nerpai�ga a �4iaig�`�$r^i d 6��3a�R�n ,��
W
w
w 5i8 S88� o`n SERE

- - start-up & operation - -
25A�PERFORMANCE
GUIDE
ZSA X 850' WATER -REEL PERFORMANCE
INCHES DEPTH OF APPLICATION
NELSON
SPRINKLER
STSTM
'IRIiMT®
TRAVEL SPEED - FEET PER HOUR
SR1Q0
PERFORMANCE
i1M
AREA
A HOZ--
PSI
arm
I OR
PSI
Wll7iH
x
iltm
35
50
75
100
Jim
150
175
.71Z'
S0
74
220
74
154
x
tl97
1.0
0.8
0.5
M4
0.3
U
U
Ring
60
81
225
88
165
X
902
1-0
0.8
0.6
0.4
0.3
0.2
ar .6'
70
88
245
99
172
X
906
1.1
0.2
0-0
0.4
2.3
0.3
01
Taper
N
94
255
111
179
x
902
1.1
0.2
0.6
0.4
0.4
U
0.2
.768'
50
81
ZZ5
79
1S8
X
9"
1.2
0.9
0.5
1.5
0.4
0.3
0.2
Ring
60
95
240
92
168
X
904
1.2
1.0
0.6
0.5
0.4
IL3
0.2
ar.65"
70
104
250
106
175
X
908
1.3
1.0
0.7
U
0-4
IL3
0.2
Taper
60
111
255
119
lad
X
1113
1.3
1.0
OJ
0.5
0.4
0.3
02
.512'
50
100
230
84
161
x
9M
1.3
1.0
0.7
1 0.5
0.4
0.3
11.2
Ring
60
110
245
99
172
X
NO
1.4
1.1
0-7
U
0.4
0.4
91
ar.7'
70
111
260
112
182
X
911
1.4
1.1
6.7
6.5
0.4
0.4
Q.2
Taper
80
127
275
127
153
X
918
1.4
1.1
0.7
0.3
8.4
0.4
0.2
.857-
50
115
240
91
166
X
904
1.4
1-2
Q8
0.6
0.5
0.4
0.3
Ring
60
125
250
106
782
X
911
1.4
1.2
0.6
0.6
0.5
0.4
0_3
ar .75'
70
135
27S
122
193
X
916
1.5
12
0.9
0.6
0.5
0.4
0.3
Taper
80
145
US
138
200
X
9Z0
1.5
1.2
0.8
3.1
0.5
0.4
0.3
.325'
SO
129
250
98
175
x
908
1.5
1.2
0.5
0.6
0.5
0.4
0.3
Ring
60
141
270
115
119
x
11s
1.6
1.3
0.5
0.6
0.5
&4
0.3
ar.8'
152
290
132
203
X
4TI
1.6
1.3
0.8
0.6
0.5
0.4
0.3
Taper
10
153
300
149
210
x
925
1.6
1-3
0.9
0.7
OA
0.4
0.3
.927'
50
150
255
111
172
X
909
1.9
1.4
C9
ILT
O's
0-5
0.3
Ring
60
164
275
130
133
x
216
1.8
1.4
1.0
6.7
ILS
0.3
0.3
ar.85-
70
177
295
149
207
X
223
1.8
1.4
1.0
4.7
0.6
L5
0.3
Taper
HOURS FOR 950 FEET OF TRAVEL:
14.3
17.0
11.3
8.5
6.8 1
5.7
4.9
sysum rule[ presort at MM aeare 13 for T011148 DMU. Engtae ortm =Ali tie appraz III Fit lawrr.
ifts Co. my m7 depwOM an vied eeodtthas, Lind dlnsaxio s sd we at aaapeettlad :prtekfera.
The vmmne wwx tomato par net Is i-1 acres.
no `S) elm Inlet Presort' Is The presrrre rtgoired at the trantar bill. n Includes ■llowanLrs Iar Ihr Invsiar pWmbIag mad
drive, PE tabs wd sprinkler preasws. Turbine drtws wtil ngnirs additional prascnre at higher age aft It dace not Include any
prouvre atiamncts for field olmUon or malaltae presslrre Iota.
Uaa the &mail 4aarbo= pultry at geared apaads above 75 last per how.
NOTE: Spedfleatioas an sepleet in ;"gilt wilhoat sauce.
20
4
. 4
49

ENGINE DRIVE Curve4117 Page I
Dated 1-3-72
to
•
Is

r
LISTERAVECO POWER UNIT
WATER-COOLED
January 1,1996
LPU.WC
MODEL
NET CONTINUOUS HORSEPOWER
LOWEST
FUEL
CONSUMPTION
ENGINE
SPEED RPM
1600
1700
18M
1900
2000
1 2100
2200
2500
LPW2
9
10
11
11
12
13
13
is
280 0 2000
LPW3
14
15
16
17
18
19
20
23
_3$0 a 2000
LPW4
18
19
22
23
25
26
27
31
.380 0 2000
LPVVT4
28
31
33
35
36
39
41
43
.400 9 1800
803i1
34
36
39
40
42
43
44_,
48
W2 0 1800
1. NET CONTINUOUS HORSEPOWER rating includes fan, air cleaner, and muffler,
if equipped.
2. LOWEST FUEL CONSUMPTION is in Iblhp-hr:
Gallonsthour = Actual hp x lb/hp-hr
7.076
3. DERATING:
N.A. gVgines:
Temperature - 2% per 10°F above 85°F;
Altitude - 3.5% per 1000 FT above 500 FT
Turbocharged engines (LPWT4):
Temperature - .3% per i 0°F above 85°F;
Altitude - 2.5% per 1000 FT above 500 FT
L

Diamond ASTM D-2' _'
lPS Pressure -Rated PVL ripe
Approximate Coupler Dimensions
A
O.D.
G
Size
Gasket Race
Socket Depth
2
3.166
4 500
21/Z
3.719
6.000
3
4 434
6,000
4
5.603
5.000
6
8 252
6.250
8
10.420
6.500
10
12.762
7.500
12
14 952
7.500
❑-2241 Pipe Dimensions
Minimum Wall Thickness
04105
500 ' ] 5 50q 71 SO" 20
sop 72 5 sap .
S.a 00
:;CM to
515 PSI 200 PSI 160 PSI
125 psi fo0 PSI
W 840
109
062
1.050
113
060
1 1 315
133
063
'•• 1 660
140
079 064
056
1 i1 ' 1 9W
145
090 073
058
2 2 375
154
113 091
073
2'h" 2875
203
137 110
088
3 3 500
216
167 135
108
4 4 500
237
214 173
138 110
5 5 563
258
265 214
171 136
6 "' 6.625
280
316 755
204 162
8 8 625
322
410 332
265 210
10 "10 750
.365
511 413
331 262
12 "12 750
406
6(6 490
392 311
0lmond's
1PS Pressure -Rated PVC Pipe coupler
,.,aets the requlremenls
of ASTM D-3139
Diamond
Gasket Specifications
1. Gasket configuration locks gasket in place
prevents fishmouthing.
2 Chevron seal for added pressure seating
pactty
3 Compression seal — provides a seal un
vacuum.
4 Wiper beads to clean spigot end
Diamond ASTM D2241
iPS Pressure -Rated PVC Pipe
Rieber Gasketed Joint Dimensior
:.o.
C MAX C
T
-7
.
r
a--- A
sou 10
L 00
7
Pls>re• Gsfiel
Pipe
A
8
c
SIxC
Insert
Socket
Diam
3
41r}
3 1
3
4
5 114
4 71:
4
a 1!_'
5 lr_
5 D
6'
S
6
7 131
8
5 t n_
6 718
10 1.
10
5 314
7 11<
12 11
12-
6
8 114
14 Ni
Short Form
Specification for Diarlland
PVC Irrigation Pipe
A STM-D2241-SDR41,32.5,26,or21
Diamond PVC lrngatton Pope shall be inade of
compounds conforming 10 ASTM D1784 with a
cell classirication of 12454B Diamond PVC
Irros4tiorl Pipe must meel all the domcnslonal,
chemical, and physical requirements as outlined
In ASTM D2241. -Annex. ANSUASAE S376 1,
and SCS 430-DD, and will be supplied in 20 fowl
t.1) Ing lengths

•
INSTALLATION
4
4
.liamond Agricultural PVC Pipe should be assembled and
installed with uniform and continuous support from a firm
base in accordance with the installation procedures provided
in ASTM D2321, and the lnsiallation Guide for PVC Water
Pipe (a "pocket -sized" edition is available from your
representative or from Diamond Plastics Corporation.)
Embedment matertals are io be in accordance with soil
classifications listed under Unified Soil Classification
System. ASTM D2487 and ASTM D2488.
To assemble, clean mating surfaces of the bell, spigot, and
gasket Apply gasket lubricant (furnished by Diamond
Plastics Corporation) to the entire spigot end up to the
reference mark Also, apply lubricant to the contact surface
of the gasket
With the pipe to straight alignment, push the spigot into
the bell up to the insertion line If a pry bar is used to
apply force, the pipe should be protected by placing a board
between the bar and the pipe
if norrhal force does not complete the Joint, disassemble the
Joint and examine the parts to make ce..ian they are free of
obstructions. visually inspect die completed joint to insure
the gasket has not been dislodged
Table 5
APPROXIMATE GUIDE FOR ESTIMATED RANGE OF DECREE
OF CONIVACTION VERSUS EMBEDMENT CLASS AND NtrTHOD
OF PLACEME.\T AS PERCENT Or ,STA'�aARD PROCTOR
OENSiTY OR RELATIVE: DENSM'
FOR GRANULAR MATERIALS IN PARENTI(ES15"
CLASS OF Eh1aE0A1ENT?^- I I it I III I IV
MerYlavlyd
NATEXIAL UESCRIfTOM GM14"
SantlaclEGn-el Mn.a GrAn
Fu.e G..r
►1aloatar
Sow CICJ. So IF
SP•17
optwv. rw..1.a <>r..rP. r yc
91, 919
640
born 4 Ylart KPSIM
l SW Cc.,-A.L. Metm*J 1 11 V IL 6 —5 U,.N,r P:,,V I
Cowy.x.q,q.er wvcr 9510
9S r4'I
97 rW
901R7
W rt.,rlr 471 1C)
.ba LLu
O...J1 Yt plrsale 41695
&W
I M V$
1590
.,hwV1 tf�lii
Lrn e..
`+
CeY,.etw.r. a: Yr.rallaw 1169f
9��`
ga 751
VA .�•.
nr.lpae f&#D
Hd uA
x...,.
t11 MI
F J.n•T OA cu
f.l r r ..
W 7V
1$f�l
1511411
-
Table A "%t:trrTr07c Or '&f M1DL/17lT MATLIIIAL 1LLA4.\UILA1III&%
,wL +cr14 _ CI,cl lrno% sit
Ll Alt T111
west. ■1AL CL.SM,r11LArW%
C..., 1 Swk-
.,+gf.r..let .yY1.. r..r/. rrrl IN . I In wral. 1. Y r,. —1
.I.J..L n.wul. Y.-r`F n1 __ • WYC/Y,i..4.Y ,. [•••.Y.! wr w I.�
.. _k" .In .-w M tmAw .A.II.
CIr. I• {., .. h•
.kk +r w. twls wr
YMn
w.![ y.A.L lr.--Y u..rr v.
_I Mw r
CL Iw
d
r,..lr p.Ad pw-YWa..-.L ..rJ ww.»u Wk—c— UK—
fW4r..n.MNW..r�1l.l.vw W-. NM •501n.IYJ .�11+.41
r+.r
W,fi 1rJ.J ,MN .N 61—tp1' ..dl I1W r w. I»..- .e
k.. w..r, 11. / — MFr rr 411• ....LJ_ Ir
Sr
P+.Ir rran+ _H ,.+ i•--rrr �•^�• t.k r w tw,n .L-. r. 14A .
hares l.r..e. 00. l,..F Yr_r d- qi%_ rJ,r �• 1n .. •. Li
r—I I.J .;
Hn ...e•- Air. /l.a kr'L .rfwnl A. H.. im •wF
-14 I.w.. _
a Hr l.•.+! M.-M YR__ x I w 1+�I.r,»..1
' Sol
%.,J .» n —,d .A .rr, . M.w, .Y.. Seal 4 ---
1A..r Yew UP% ..u».d .r. M1.. ,a.Mn
K
rlay.t ..& _,4 I[q r...,. ►V., ti - 14tt .a .,.,,., hw,. -. r... .
kr-r MR ol,•w *I rcr...4J.+Ar l0+w-.
F1L
I—&—w4 ..ry lest ._y. �.i f7r w .».k..•'- •�
SnG .r +n1 yOSrn,... /q... l.» Tsl .,•.
CL
Les.»...w .I,7, rl k... .. .L AwA j.Y.w, ,� 1.. .Y.. ,_. 1
r,.l» 1h.... Lr 5r.4 Yr w w».1. rr._ • Iw. ;... ..
C7r
r..t... n.0 .f
. rn,r- H•. J4 0 u•.
CI-. , S.nk IL
4h,_ .0..4 41w. W.r . W, ■ Y.. rl.-». •. 1 .,,.J M.. ,I. .. ,.
OF
[k[a.a rf.r. w( w.et..w .. FM 1a+rr-+r Ly..w ...w ....w i ww ,I•. +•'
— r...e1 1rr mo ,...
t PT ,
R. .,-ri »W .41... 64M, .Mire ,.rl.
•>...�..r....Yr..[a,.�srwai.av�v.P.1..rci...,......r...r..rJ.c,..l,...t.lu:l•1
• r. 4u..M.t -,M ASr}. D 2431 W.0— 31L M.
••• i» x.wu.wc. .w. ASTAI 0 :.17 —I. -- Si zw ,:S p•••a.F W h.• ..., I...
11.114.[1.. 6.1 .1 wrr t►aaru .1 cu.. u 0.n.4 Cr.n III
The haunching area is most important to the support
PVC pipe For good support, the haunching area should
compacted to the densities given in the Long Te
Deflection Chart
Figure 2
A, .
Y[I'Y.,.L a .... ,.ca .. ry(y Fl Y.

9ONSTRUCTION NQTES
Use Class 200 Gasketed 14" PVC pipe.
Use Schedule 80 Fittings
Install pipe with a minimum cover of 30".
Do not dig trench beyond changes of direction or ends of mainline -- must
have undisturbed earth to support thrust blocks.
Dig a wedge into the trench bank to form the thrust block area.
Refer to the design for thrust block calculations. Use no less than the
minimum required area of concrete.
Install 2" air reliefs (AV150's) where designated by "AN." on the scaled
Is drawing(s).
A technical specialist with "I" designation must be notified 2-3 days before
installation so that he/she may schedule inspection visits during installation.
0

C'
Field Calibration Procedures
for Animal Wastewater Application Equipment
HARD HOSE
AND CABLE
TOW TRAVELER
IRRIGATION SYSTEM
General Guidelines
Land application equipment used on animal production farms must be field
calibrated or evaluated in accordance with existing design charts and tables
according to state rules that went into effect September 1, 1996. Technical
Specialist certifying waste management plans after September 1, 1996, must
also certify that operators have been provided calibration and adjustment
guidance for all land application equipment. The rules apply to irrigation sys-
tems as well as all other types of liquid, slurry, or solid application equipment.
Information presented in manufacturers' charts are bwed on average op-
erating conditions for relatively new equipment. Discharge rates and applica-
tion rates change over time as equipment ages and components wear. As a
result, equipment should be field calibrated regularly to ensure that appiica-
tion rates and uniformity are consistent with values used during the system
design and given in manufacturers' specifications. Field calibration involves
collection and measurement of the material being applied at several locations
in the application area. This publication contains step-by-step guidelines for
field calibration of hard hose and cable tow traveler irrigation systems.
Operating an irrigation system differently than
assumed in the design will alter the application rate,
uniformity of coverage, and subsequently the applica-
tion uniformity Operating with excessive pressure
results in smaller droplets, greater potential for drift,
and accelerates wear of the sprinkler nozzle. Pump
wear tends to reduce operating pressure and flow.
With continued use, nozzle wear results in an increase
in the nozzle opening, which will increase the
discharge rate while decreasing the wetted diameter.
Clogging of noziles of crystallization of main lines
can result in increased pump pressure but reduced
flow at the gun. Plugged intakes will reduce operating
pressure. An operating pressure below design pressure
greatly reduces the coverage diameter and application
unlformity. Field calibration helps ensure that nutri-
ents from animal waste are applied uniformly and at
proper rates.
The calibration of a hard hose or cable tow system
Involves setting out collection containers, operating
the system, measuring the amount of wastewater
collected in each container, and then computing the
average application volume and application unifor-
mity.
An In -line pow meter installed In the main
Irrigation line provides a good estimate of the total
volume pumped from the lagoon during each irriga-
tion cycle. The average application depth can be
determined by dividing the pumped volume by the
application area. The average application depth is
computed from the formula:
Average application depth (inches) =
Volume pumped (gallons)
27,154 (gallac-1n) X Application area (acres)
The average application depth is the average
amount applied throughout the field. Unfortunately,
sprinklers do not apply the same depth of water
throughout their wetted diameter. Under normal
operating conditions, application depth decreases
towards the outer perimeter of the wetted diameter.
Big gun sprinkler systerns typically have overlap
based on a design sprinkler spacing of 70 to 80
percent of the wetted sprinkler diameter to cornpen-

Fiefd Calibration procedures
for Animal Wastewater Appiicati+... Equipment
sate for the declining application along the outer
perimeter. When operated at the design pressure, this
overlap results in acceptable application uniformity.
When operated improperly, well -designed systems
will not provide acceptable application uniformity.
For example, if the pressure is too low, the appUca-
tion depth will be several tirnes higher near the
center of sprinkler and water will not be thrown as
far from the sprinkler as indicated in manufacturers'
charts. Even through the average application depth
may be acceptable, some areas receive excessively
high application while others receive no application
at all.
When applying wastewater high in nutrients, it is
important to determine the application uniformity.
Collection containers dtstnbuted throughout the
application area must be used to evaluate application
uniformity. ,
Many types of containers can be used to collect
flow and determine the application uniformity.
Standard rain gauges work best and are recom-
mended because they already have a graduated scale
from which to read the application depth.
Pans, plastic buckets, jars, or anything with a
uniform opening and cross section can be used
provided the container is deep enough (at least 4
inches deep) to prevent splash and excessive evapora-
tion, and the liquid collected can be easily trans-
ferred to a scaled container for measuring. All con-
tainers should be the same size and shape to simplify
application depth computations.
All collection containers should be set up at the
same height relative to the height of the sprinkler
nozzle (discharge elevation). Normally, the top of
each container should be no more than 36 inches
above the ground. Collectors should be located so
that there is no Interference from The crop. The crop
canopy should be trimmed to preclude interference
or splash Into the collection container.
Calibration should be performed dung periods
of low evaporation. Best times are before 10 a-m. or
after 4 p.m. on days with light wind (less than 5
miles per hour). On cool, cloudy days the calibration
can be performed anytime when wind velocity is less
than 5 mph.
The volume (depth) collected during calibration
should be read soon after the sprinkler gun cart has
moved one wetted radius past the collection gauges
to minimize evaporation from the rain gauge. Where
a procedure must be performed more than once,
containers should be read and values recorded
immediately after each setup.
Calibration Setup for Hard Hose and
Cable Tow Traveling Guns
Hard hose and cable tow traveling guns are calibrated
by placing a row (transect) of collection containers or
gauges perpendlcuiar to the direction of travel, Figure
1. The outer gauge on each end of the row should
extend past the furthest distance the gun will throw
wastewater to ensure that the calibration is performed
on the "full" wetted diameter of the gun sprinkles
Multiple rows increase the accuracy of the calibration.
Containers should be spaced no further apart than
l/ 16 of the wetted diameter of the gun sprinkler not
to exceed 25 feet. At Ieast 16 gauges should be used in
the calibration. Sixteen gauges will be adequate
except for large guns where the wetted diameter
exceeds 400 feet.
(Maximum recommended spacing between
gauges, 25 feet X 16 ; 400 feet.) Gauges should be set
at least one full wetted diameter of throw from either
end of the travel lane, as shown in Figure I.
The system should be operated such that the
minimum travel distance of the gun cart exceeds the
wetted diameter of throw. Application volumes
should be read as soon as the last gauges stop being
wetted.

Row of
Collection ----i
gauges
Direction of travel
Reel cart -- --311
Left I Right
8 7 6 5 4 3 2 1 i 2 3 4 S 6
0 0 0 0 0 o 0 o 1 o a 0 0 0 0
Gun
cart
Wetted diameter
(320 feet)
4RD HOSE AND CABLE TOW TRAVELER
IRRIGATION SYSTI;MS
7 8
0 o n
}
At least one wetted
diameter end of ReM
Figure I. General layout and orientation
of collection.gauges for calibration of a hard hose and cable tow traveler irrigation systems.
I CALIBRATION PROCEDURES
7. Determine the wetted diameter of the gun.
2. Determine the number of collection gauges and spacing between gauges. For a wetted diairieter of 320
feet, the rain gauge spacing should not exceed 20 feet. (320 ft / 16 = 20 ft).
3. Label gauges outward from the gun cart as either left or right (1-1, L2, L3, etc; R1, R2, R3, etc.)
4. Set out gages along a row as labeled and shown in Figure 1, equally spaced at the distance determined In
Rem 2 (20 feet). The row should be at least one wetted diameter from either end of the pull. The first
gauge on each side of the travel lane should be I /2 the gauge spacing from the center of the lane. For a -
t
gauge spacing of 20 feet, LI and RI should be 10 feet from the center 0f the lane.
5. Operate the system for the time required for the gun to completely pass all collection containers. Record
the "starting" time that wastewater begins to be applied along the row of gauges and the 'ending" time ; J
when wastewater no longer is being applied anywhere along the row. Also record the distance traveled in -
feet for the time of operation. f
6. Immediately record the amounts collected in each gauge_ (Refer to Table I for an example.) -.-
7. Identify those gauges that fail outside the effective lane spacing, Figure 2. This volume Is the overlap
volume that would be collected when operating the system on the adjacent lane.
S. Superimpose {€eft to right and vice versa) the gauges Just outside the effective width with the gauges just
Inside the effective width. Add the volumes together.
For the layout shown in Figure 2, add the volume (depth) collected In gauge R8 (outside the effective ;
lane spacing) to volume (depth) collected in gauge 15 (inside the effective lane spacing). Similarly, R7 is
added to 1.6; L8 is added to RS; and L7 is added to R6. This is now the application volume (depth) within
the effective lane spacing adjusted for overlap.

Figid Calibration Procedures
for Animal Wastewater Applicz Equipment
{,one 1
Lane 2
Red cart
Left
Right
8 7 6
5 4
3 2 1 1 2 3 4 S 6 7 8
0 0 0
0 0
0 0 O 0 0 0 0 0 0 0 0
Left
light
B 7 1 6 5 4 3 2 1 1 2 3
4 5 6 I7
8
Gun
��
0 0 0 0 0 0 0 o 0 0 0
0 0 0
O
Direction of Crave! Cuncart
I
I
1
#
#
�
Effective lane rbg
(224 feet 4�
Effect lane rig
feet
!�
(224
#
Figure 2. Accounting for overlap
I
�
when Calibrating a hard hose traveler system.
CALIBRATION PROCEDURES (continued)
9. Acid the amounts collected in all gauges and divide by the number of gauges within the effective area. This
is the average application depth (inches) within the effective lane spacing.
Sum of amounts collected in all gauges:
Average application depth
Number of gauges within effective width
10. Calculate the deviation depth for each gauge. The deviation depth is the difference between each • ` •�
individual gauge value and the average value of all gauges (#7). Record the absolute value of each
deviation Depth. Absolute value means the sign of the number (negative sign) Is dropped and all values are
treated as positive. The symbol for absolute value Is a straight thin line. For example,121 means treat the
number 2 as an absolute value. It does not (Wean the number 121. Because this symbol can lead to �
misunderstandings, it is not used with numbers In the worksheets at the end of this publication. The
syriibolis used in formulas in the text, z. f
.t
Deviation depth = IDepth collected in gauge i — average application depth]
"i" eefers to the gauge number
11. Add arnounts in #10 to get "sum of the deviations" from the average depth and divide by the number of
gauges to get the average deviation.
5um of deviations (add amounts computed in #10)
Average deviation depth =
Number of gauges within effective lane spacing a
1Z The precipitation rate (inches/hour) is Computed by dividing the average application depth [inch) (#i) by i
the application time (hours) (#S)
Average application depth (inch)
Precipitation rate
Application time (hours)

(7)
ARD HOSE AND CABLE TOW TRAVELhR
IRRIGATION SYSTEMS
CALIBRATION PROCEDURIE 5 (continued)
13. Compute the average travel speed '
Distance traveled (feet)
Average travel speed = i
Time (minutes)
14. Determine the application uniformity. The application uniformity is often computed using the
mathematical formula referred to as the Christiansen Uniformity Coefficient.
It Is computed as follows:
Average depth (#9) -Average deviation (#i 1) '
U= X 100
Average depth (#9)
15. Interpret the calibration results. The higher the index value, the more uniform the application. An index of 4
100 would mean that the uniformity is perfect — the exact same amount was collected in every gauge. -` a
For travelers with proper overlap and operated in light wind, an application uniformity greater than 85 is -`
L
Common.
Application uniformity between 70 to 85 is in the "good" range and is accepta ble for wastewater
application.
Generally, an application uniformity below 70 is considered unacceptable for wastewater irrigation using
travelers, If the computed Uc is less than 70, system adjustments are required. Contact your irrigation
dealer or Certified Technical Specialist for assistance.
Table 1. Example calibration data for a traveling gun system operated in parallel lanes. Lane
spacing 74 percent of sprinkler wetted diameter.
a.
Manufacturers' Specifications: Gun Model¢ Type Taper Bore
Nozzle Oia. 0.9 inch Pressure (Gun) ZQ p'r Reel 105 obi �
Wetted diameter 320 fit Effective Spacing Z24 [t flow 197 GPM
Rose Size: Length 4Q_ft Dlameterl-in
b.
Spacing between collection containers (spacing 3M(ft)1 16) 2Qft
c.
Number of gauges =16
d.
Start of irrigation event l;] _a.m. ;
e.
End of Irrigation event 9;00 p.m,
f.
Duration (e-d) i-0 minutes
g.
Travel distance 320 feet
h.
Operate the system and collect data,

Field Calibration Procedures ~
for Animal Wastewater Application Equipment
Table 'I. Calibration Datai(condriued)
Gauge Distance Volume
Overlap
Corrected
Deviation
No. from Center Collected
Adjustment
Volume
from Average*
(feet) (inches)
(inches)
(inches)
(inches)
Ll 10 .94
.94
.235 (1 - jj
i
L2 30 .80
.80
-095 (2 -
L3 50 S9
.59
.115 (etc)
L4 70 .61
.61
.095411
L5 90 .50
.13
.63
.075
-3
L6 110 ,42
-20
.62
.085
.: f
�•i
L7 130 .33
L8 I50 .07
R1 10 .73
.73
.023
R2 30 .81
.81
_105
R3 50 .92
.92
.215
R4 70 .64
.64
.065
RS 90 50
.07
S7
.135
R6 110 -27
.33
.60
.105
J
R7 130 .20
IRS 1 SO .13
"Absolute value; treat all values as positive.
I. Sum of aifboiumes collected in #h $.46 inches
j. Average catch (/number of gauges within effective width (12) 0, 705 inches
Distance traveled (ft) 320 ft
k Compote the average travel speed = = 3.04 ft(min
Time (min) 105 min
average depth (inches) 0.705 In
I. Precipitation rate = = a 0.40 in/hr
application time (hour) 1.75 hr
m. Sum of deviations from the average catchJJ56
n. Average deviation from average catch (m/12) 0,113
o. Uniformity coefficient
0.705 - 0.113
U,= 0.705 X100=2A
p. Interpret results. Uniformity coefficient of 84 is in the goad range for a traveler system. No adjustment
is necessary.

A
ARD HOSE AND CABLE TOW TRAVELi ft
IRRIGATION SYSTEMS
Irrigation System Calibration Data Sheet for Hard Hose Traveler Irrigation System
DATE: Land Owner Farms No.
a. Manufacturers' Specifications: Gun Model Type
Nozzle Dia.n Pressure (Gun) (Reel)
Wetted diameter ft Effective Spacing ft Flow GPM
Hose Size: Length ft Diameter in
b. Spacing between collection containers (diameter 1 S) = ft
C. wetted diameter (ft)
Number of gauges =
gauge spacing (ft)
d. Start of Irrigation event
waft -----.
Uft w*
e. End of Irrigation event a r c s • s: t t s+ s r r a
i � �oi00000a oaoeoo[ o
f. Duration (e-d) iTlln a ol0 e a o� 0 00 o e o 0 a all
g. Travel distance feet ! I
h. Operate the system, collect data,
and record on the worksheet on page 8. I
I. Sum of all catches inches
I
j. Average catch (i/number of gauges) inches
l
Distance traveled (ft)
k, Average travel speed = _
Time (min)
1. Sum of all deviations from the average catch
rn. Average dtViatlon from average catch
n. Uniformity coefficient
V. = X 100 =
Interpret the Calibration data and make necessary adjustments.
For travelers with proper overlap and operated in light wind, an application uniformity Coefficient greater than
85 is common.
Application uniformity between 70 to 85 is in the "good" range and is acceptabie for wastewater application.
Generally, an application uniformity below 70 b considered unacceptable for wastewater irrigation using
travelers_ if the computed U,, is less than 70, system adjustments are required. Contact your Irrigation dealer or
Certified Technical Specialist for assistance.

;» � T i:�'��"i a! - �V� il.�!.:i � �:�•�1•`, -!•v=`.:?7�'FS`�; i '�i•^ �' '• AIXV9
.-1�`•;. sf ,�, •r-: i.-'[:-
., �J4fh r'r 1 �� t.�� _ �. -l`•.r fy.If,. 1: ,7,,':,,. '. .,: - - -,,,,;
'• IC.• i �-1•�r I{ rl f l: o" H'�•r.,etr'I � i� r 7/f ,��t ��1�',.y. [ ,]►�r %r l � � +� ,;; '.} : J.
- :%Il [r' • � I S� -f 11 JnP ��f�'t ttiJ r • r � [ • r '� r- 3� --�E;
l w .r .ter 11 V� �+� + ;♦� -
,t[ j�.L- t��i `+[- �• � -sj. .� 1 4�: .Y Sr � i-�1-r.},� r . } i�l�
aL
� � !��r, =;1�'{-;.t.� i�''•��a: ��(��[LL` r 1-t N �� j�#i%,�T��,}jA�if_ y ` rs':�
%4914Irtit—
r-.: � ,r�:; : , _ •i' .�, �'..•. - . 4 _ - - - -
� - , � ,� , � --• / we ���" :`i'^'r.��Jr � a, r -t � I j _
� ,�. � [ ,� -- _�' _ -::�. • ��.}ti S �� e�:, ; r„tr�>vTt.�i..r �y ;Yf'+':� f � { � - 4� %'" +
Mz",x-m",
�,� jy... 4ry'^i_ .••-A� '•� �-t f'S J .sJ-IC... �, '� I T
r is �•�rt�l' �� �lL` ryylSy yyT" 1 �S -
r-
1i t f,
-r- }'t �` �, r7 - ILr r li S� r - ,1 •r f� r
'• r r i< - e� i r.i-^ r ♦ 1 _!^� - ,^"J - � J�7 s 1. � � � - -_ -
-
t tit > Y5 1- !1-t*-, tit 7 ij •t^ei- tt'�, i e i'. Y ,- rat• S [ "' ._ r 4
.t 7�a.}r yf krFt Fb i y a>,� t • r j
L� a'S:J �rY
C 1 i -4 [- ' 3• �--[ � r' °r t`•"i'1 `:ry.�-.:, 1��� �irzrk.S 'L ..,,i.r����*��[�'.♦ t' } f ,' F � i'��:k:�: - f.-4L:; :.
4 J. . r 5 r, 1 r1f '-y -+r` �1-a-.r.,iFi-+,4� .}ti 1il"�11 -5` '4 t -. •'� �! •Y VI
-�> t;Q::. 'r1 r fjt
s. },f.p�S t -,� � �' r 1J c�' 5'rr +,a"+ y'•+f ���r��i l* � r ,r .� r r F � L �, r�
f Z ZC z. GSM 5 irt�{
_ ff 7Ca ?, r •� �j`�r C-.,L3St �e i t c 1-
•-Sr -c tr� � r «•-� - '" C-.C'; t5J[, - ,4 Syr Y'4 rrl 41 „+ �1< ,-. .r
r :4�{.3�ni l Ss, .•- L! ry1rJ l - a \ _ LrC �_ i♦ +r. + _ 4yf K ` {«1 7` S'1.ry NiJ'L-+.t[[ck�� cYIj .�n'rfy _. .r• r -a a �1 r r, Js
F + -s •'.�! t '�- iL �+ r. � :'t t [_~i"' `rik rJsr, 4-i `''i%- 5+: • r�rrr:
- _ Y r� r.r, 1 ♦F ��', _ '�. r,� ��-�.i•.�+1 . i4r ti r»�-4 :y. 51 ✓'(-1 � �
r _ r '~ f F •i-'+.�1" 'c' L -I, ff 11i �, s �J,�•i �ZS fy...i - �j �, r+� [ r r �;rli
j ar ' _ r t7 - �" -w �13 { i Ff f4:1 f 1, ]' i.,1, 1 y1 ..4• `xr � - � -L 1 ! 4 • r7
6IYe�I�{?d; }'[`'�S+•[t. [�;N ±.3, 4y� t 1 r1- t • r��. "-,t 1 L•. �. -] 1-1',
S ` rti- I. ti• - r r:�-tr 4 -
r_ ;LI -kT ' � � _ ���.ry � "7'r� _i - .i_-, 5 „r:..;_� �•, r..C`>; ��- � �t,�r:a ,�.-: r �, �: t �,t I st; � f 'rr.
'� "' '?• i �, ,t: 'yr'r;,;: �,j ter i-r +:,-rr�!!(,,,_ry�•C:�=1'�,�,. _,' r-,.,,,••r ►i •r' 1 �r
i�.?�1 •cam y ,-i /.r t �rr r .3V �,;!• �r ;y'r:i: [! t _+M"� },� •4 ty� FS;,`14 .71' rC17�f �J., As 4' 'r .ti L }.: _
r . r . 1 + •s; f, :.l',' i-CF:: •i , ii'� ]`r �a �• �s x ' -r
�r ♦ � 1 rL /. �[- - r�[ 1, ti� :+s :a7 s,1; ri ft+ Si J + �r
7 S 't f' -r r� �} v's'?+�iirir( ,,i!fZi�'.`J":.Si•+f� t`(4i'r •- 1 rye r y` ',, I r�'
�'7'. ; r � -rx r z �! . Jc.' .+f f � ^..rr .... t ��-F:�`" S'�,�_li . ' j-{ t 1.- _ t = •krir •� r, ["•r . ._.y;>, {- '. � -.+'- �' ;J<Jr „..rY -tit; .,�['i.i ,{!.:4q T �-+_ ; � �1ti1, .i��tT+ rr ?;+,`,i�.'.r'�- �ru•; 17 ;f . � �-';-': c: �J" .,•s' ''r.' s�= T
S r S _ '�r� �'�. yL� � kt r'�•��;i=l•'~ } [/ Ls ':t,, ��.�Y�. .%l"-�ie'..yyl`Vk � l7 r L: ::.= ' .._� • y - �- S4. ��'
, - s.S +l�;t- � ,_;� � .�:. ' .,, t .i�. � eA 1 ,. 3 _ y r,r r-'r••1' J ��y
a i -,' t 1.1 •: ir1 .s J �S-�.�.r:�-, �;+��1-ri� 5fr.: Via. �yl.t lrrtyt? �'t` T' a' J`[ ` ti' {--� 7�•,•,i
7 r'�•" �- [ i '- i ♦k' LCC �r' al t f=*y'.�n"5�, S7. [-✓•I, -.- v 4 i 11 Ta«• f ti's
• t :�� _ !",3Y}-,!`;'•�-+; :•.. �cFti�+} h k-,•''• }�..}�'✓ [ ♦ r.:Y l �- 4 f• r _ -S� y`J`J
`r r _ ,f-- T, 4 .`7'. L_*�r.^:y r r- �� '•' },t• rti fks iv�.�lf : r/ S � 1 r 7 r r- f
r i r . � � 4, r�LJ� t. � 4Nlt•rrF. �S[�1`-. �r�� f1;-w- - J i. '-3 [ 4 _ r,Ji L
�� L 1 "I••t�-.w jo,�r �Yj1�{A r ty't.�r� 1 7.se tnJ •t �I "t t- E
.+,,.-• + .r � i} 3-ra a X t r -r �-,r,jl(t`. J�;Si�, r - a :r?
- f J r -:r �e�{- � •`J :.r .t..� •\,r� r ✓�f �, _ I. v J. -� _-,f _ -f ,
,r + _ r r '"� r.� / J•.jr v a y �` pT � , - � " [ -.'tM
.1q ! - r'. rt - ti� r S�:f 1 i� �l 3i •;,,, ;=�<I _: r� � I }�' r_ ' r
• cl "a` 'ri' c f
_ r �- ' ' [-_ 7.• _ a L F � t�,��-. .�. ,, ril:3• •' "��c - ;y i f rt r 1�4 �'
lr t -�, lr � !r,'irs y,E s,�Cr4 ra. . rl`nr r ..r ye' tCr +J- }•
__ -s _- - �_ y=„„t. � ,� .��zl r.�ti ��.J�i�;J'P.-t�ryr4''a"lt�s^lr= r-• ,t - lY � /-,.�.
•�. �". � i - .-t� t F' '!`L. w �,• r i. +• e•,�rr y,t r �
^.' i � -. . 4` - r,'t. < : ,Y'�. f t ? �*: "'. Cf �t�_t.{.1r,ry:-11 J +- -i s � r �, i„
4.:}Y+ ^;-r _ ,-+ s `.l�5 lr -;i^ n�' ,r���w.r'ff' t;tixN,t•� ��yi` ��e+ r„ t !; _
:., f r [ , 4 - f �'%r r t }" i;4'# • " t� �' •!^� I I .1 t i - � r -
�
`� , `R . 4.t�r 'JL�J%�'ra d 'J' I. }`r ♦ } J ,7 r - F le r _ ti [ r - ) ~..:�'. ! r � L[!-�.��- .. �-} 'art[! � �,.�nj, t�µ-i l �'i'>iG'rt1 1�3rt '� pC 4 _ � i _ � `,
t ry c74,r
r:�r
1.. "Y fJ 1 1. ::i:r,.. sij'_.1J +'»..1I f a-4rr" .�.tl7��'j� r- L M l•'1"`� i�+��4 I• � � rS. -"1 � i r.7.r_ c[.� 7�
- -f:.,r-� !'� ,., 11 r .•S-;vi`�4 i��"1� k?Y"'S>• 7jJ •r3..'' ��. �y tl 4 F•F ='-¢. -�' � � - •t'.-!_t'.r' s':
-y d ♦ J. i.�[ti { i Sk {a fit c ✓ r"♦ 6 Y _ ., .-i•��`;��':.•'" r�i Y.^•,...
,1� _ " -7 a .c.P:: J• if.'.' r1'`r +,7{�%L�'-Y,� wr�.+'i�r' � �.�'�� .�:.�7,�z �rr 1 -- r r- �S r � S r 'r - i 3 �.. V . f ^ r a,.-r � 5.. .•r :r: , .[ %Y'"''`•i g'. � L- it- Sr ; � - f 1. i ` t Z
_ _-, - , - ti ' ,.. 7 Y 7':J-:,! ' '{ i ;i"' f..'` , -: , s !?4r .;j'�,.z'� ,:f%'�,� •!"iS�Cwis "'; {�'.4„r , -L s'S •r� '�U .. : s r -• jh [. �I
�S �' `
L'!7-7�tyyf,,,� %:i �t•��r:-.�•'• y `� y'1iajy�'r�' M1-� t~N �y z •r' j t'- p r,4'
' - .-• .-. 7 ., [4. ti;-.:, �._. ri.k.4; L:i{'_<Jc%::ihS,,.. _ �..•;.'.•a _.c }..C•ic.:�--r•

CHINQUAPIN p
ELECTiON Nr
PRECINCT � .� tzs.79Ar
irra 04
,
AIl1 o7.a 2o7.a 207. .�~--ROAD• 12100;
,� o a v CYPRESS CREEK `f2o6D� A�
0
°Q ° ° ELECTION PRECINCT
g99.r$ (29.24A)
- 3600 004
(2.01AI (2.oIA) (2.05 A
Al 0127 2127 4127 0 (29.77A)
)3 2o7.a 207.4 1 2074.4681
622.2
w
?v, A
�%9 o - a„ �r., 0
(24.47A)
5 314
cs�.a3A1 W � -
6089
�ry lip
Ze 90
,
� � Q
fsJo
q ,
' I

CHINOUAPIN
o
ELECTION
�
PRECINCT
tzs.Tsaf
Otto --lf
o548
---.-�. 12rpo1 4
R dp
MER — "---A=
207.4 207.4
207.ro
o o
CYPRESS CREEK
rc2os0j
°D °° OD'
o
m
ELECTION PRECINCT
0127 2127
4127
029.77Ar
207.4 207.4
247.4
40Bt
622.2
o
�,
w
Aoj/ev
ml
-►ys.ra
(29.24A1
gi3600��
(p�
a
Pl'
124.47A!
ogr;91
?">
V
'9p
9

CHINOUAPIN
ELECTION P
PRECINCT M t2s.7sa)
n548
fuo�\ o
R04i) f,
207.4 1 207,4
207.
!s A
"f2
CYPRESS CREEK
°
ELECTION PRECINCT
f2.01A)
0127
12.0tA)
2127
(2.05A
4127,
o,
o
129,77A1
207.4
207.4
207.4
Z74681
622.2
tD
��+
IoLK %lOOJL�
999,f8 (29.24A)
36C30
(10.2MA)
+n��• (24.47A)
5 314
�ieTs
h~

OPERATION & MAINTENANCE PLAN WAR R Q ETV E RECEIVED ON
Proper lagoon liquid management should be a year-round priority. It is especi;�
important to manage levels so that you do not have problems during extended 5 1999
wet periods. Non-Discha
nge Permltbnq
Maximum storage capacity should be available in the lagoon for periods when the
receiving crop is dormant (such as wintertime for bermudagrass). or when there are
extended rainy spells such as the thunderstorm season in the summertime. This means
that at the first signs of plant growth in the aaer winter/early spring, irrigation according to
a farm waste management plan should be done whenever the land is dry enough to
receive lagoon liquid. This will make storage space available in the lagoon for future wet
periods. In the late summer/early fall the lagoon should be pumped down to the low
marker (see Figure 2-1) to allow for winter storage. Every effort should be made to
maintain the lagoon close to the minimum liquid level as long as the weather and waste
utilization plan will allow it.
Waiting until the lagoon has reached its maximum storage capacity before starting to
irrigate does not leave room for storing excess water during extended wet periods.
Overflow from the lagoon for any reason except a 25-year, 24-hour storm is a violation of
state law and subject to penalty action.
The routine maintenance of a lagoon involves the following:
Maintenance of a vegetative cover for the dam.
Fescue or common bermudagrass are the most common vegetative
covers. The vegetation should be fertilized each year, if needed, to
maintain a vigorous stand. The amount of fertilizer applied should be
based on a soils test, but in the event that it is not practical to obtain
a soils test each year, the lagoon embankment and surrounding areas
should be fertilized with 800 pounds per acre of 10-10-10, or,
equivalent.
Brush and trees on the embankment must be controlled. This may be
done by mowing, spraying, grazing, chopping, or a combination of
these practices. This should be done at least once a year and
possibly twice in years that weather conditions are favorable for
heavy vegetative growth.
NOTE: If vegetation is controlled by spraying, the herbicide must not be allowed to enter
the lagoon water. Such chemicals could harm the bacteria in the lagoon that are treating
the waste.
Maintenance inspections of the entire lagoon should be made during the initial filling of
the Iagoon and at least monthly and after major rainfall and storm events. items to be
checked should include, as a minimum, the following:
Waste Inlet Pies, Recycling Pipes, and Overflow Pipes --look for:
1. separation of joints
2. cracks or breaks
3. accumulation of salts or minerals
4. overall condition of pipes

Lagoon surface ---look for:
1. undesirable vegetative growth
2. floating or lodged debris
Embankment ---look for:
1. settlement, cracking, or "jug" holes
2. side slope stability ---slumps or bulges
3. wet or damp areas on the back slope
4. erosion due to lack of vegetation or as a result of wave action
5. rodent damage
Larger lagoons may be subject to liner damage due to wave action caused by strong
winds. These waves can erode the lagoon sidewalls, thereby weakening the lagoon dam.
A good stand of vegetation will reduce the potential damage caused by wave action. If
wave action causes serious damage to a lagoon sidewall, baffles in the lagoon may be
used to reduce the wave impacts.
Any of these features could lead to erosion and weakening of the dam. If your lagoon has
any of these features, you should call an appropriate expert familiar with design and
construction of waste lagoons. You may need to provide a temporary fix if there is a threat
of a waste discharge. However, a permanent solution should be reviewed by the
technical expert. Any digging into a lagoon dam with heavy equipment is a serious
undertaking with potentially serious consequences and should not be conducted unless
recommended by an appropriate technical expert.
Transfer Pumps ---check for proper operation of
1. recycling pumps
2. irrigation pumps
Check for leaks, loose fittings, and overall pump operation. An unusually loud or grinding
noise, or a large amount of vibration, may indicate that the pump is in need or repair or
replacement. .
NOTE: Pumping systems should be inspected and operated frequently enough so that you
are not completely "surprised" by equipment failure. You should perform your pumping
system maintenance at a time when your lagoon is at its low level. This will allow some
safety time should major repairs be required. Having a nearly full lagoon is not the time
to think about switching, repairing , or borrowing pumps. Probably, if your lagoon is full,
your neighbor's lagoon is full also. You should consider maintaining an inventory of spare
parts or pumps.
Surface water diversion features are designed to carry all surface
drainage waters (such as rainfall runoff, roof drainage, gutter outlets,
and parking lot runoff) away from your lagoon and other waste
treatment or storage structures. The only water that should be
coming from your lagoon is that which comes from your flushing
(washing) system pipes and the rainfall that hits the lagoon directly.
You should inspect your diversion system for the following:
1. adequate vegetation
2. diversion capacity
3. ridge berm height

Identified problems should be corrected promptly. It is advisable to inspect your system
during or immediately following a heavy rain. If technical assistance is needed to
determine proper solutions, consult with appropriate experts.
You should record the level of the lagoon just prior to when rain is predicted, and then
record the level again 4 to 6 hours after the rain (assumes there is no pumping)_ This will
give you an idea of how much your lagoon level will rise with a certain rainfall amount
(you must also be recording your rainfall for this to work). Knowing this should help in
planning irrigation applications and storage. If your lagoon rises excessively, you may
have an inflow problem from a surface water diversion or there may be seepage into the
lagoon from the surrounding land.
Lagoon Operation
Startup:
1. Immediately after construction establish a complete sod cover on bare soil
surfaces to avoid erosion.
2. Fill new lagoon design treatment volume at least half full of water before
waste loading begins, taking care not to erode lining or bank slopes.
Drainpipes into the lagoon should have a flexible pipe extender on the
end of the pipe to discharge near the bottom of the lagoon during initial
filling or another means of slowing the incoming water to avoid erosion of
the lining.
4. When possible, begin loading new lagoons in the spring to maximize
bacterial establishment (due to warmer weather).
5. It is recommended that a new lagoon be seeded with sludge from a healthy
working swine lagoon in the amount of 0.25 percent of the full lagoon
liquid volume. This seeding should occour at least two weeks prior to the
addition of wastewater.
6. Maintain a periodic check on the lagoon liquid pH. If the pH falls below
7.0, add agricultural lime at the rate of 1 pound per 1000 cubic feet of
lagoon liquid volume until the pH rises above 7.0. Optimum lagoon liquid
pH is between 7.5 and 8.0.
7. A dark color, lack of bubbling, and excessive odor signals inadequate
biological activity. Consultation with a technical specialist is recommended
if these conditions occur for prolonged periods, especially during the warm
season.
Loading:
The more frequently and regularly that wastewater is added to a lagoon, the better the
lagoon will function. Flush systems that wash waste into the lagoon several times daily are
optimum for treatment. Pit recharge systems, in which one or more buildings are drained
and recharged each day, also work well.

Practice water conservation ---minimize building water usage and
spillage from leaking waterers, broken pipes and washdown through
proper maintenance and water conservation.
Minimize feed wastage and spillage by keeping feeders adjusted. This
will reduce the amount of solids entering the lagoon
Management:
Maintain lagoon liquid IeveI between the permanent storage level and
the full temporary storage level.
Place visible markers or stakes on the lagoon bank to show the
minimum liquid level and the maximum liquid lever (Figure 2-1).
Start irrigating at the earliest possible date in the spring based on
nutrient requirements and soil moisture so that temporary storage
will be maximized for the summer thunderstorm season. Similarly,
irrigate in the late summer/early fall to provide maximum lagoon
storage for the winter. -
'T'he lagoon liquid level should never be closer than 1 foot to the lowest
point of the dam or embankment.
Do not pump the lagoon liquid level lower that the permanent storage
level unless you are removing sludge.
Locate float pump intakes approximately 18 inches underneath the liquid
surface and as far away from the drainpipe inlets as possible.
Prevent additions of bedding materials, long-stemmed forage or vegetation,
molded feed, plastic syringes, or other foreign materials into the lagoon.
Frequently remove solids from catch basins at end of confinement houses or
wherever they are installed.
Maintain strict vegetation, rodent, and varmint control near lagoon edges.
Do not allow trees or large bushes to grow on lagoon dam or embankment.
Remove sludge from the lagoon either when the sludge storage capacity is
full or before it fills 50 percent of the permanent storage volume.
If animal production is to be terminated, the owner is responsible for
obtaining and implementing a closure plan to eliminate the possibility of a
pollutant discharge.
Sludge Removal:
Rate of lagoon sludge buildup can be reduced by:

proper lagoon sizing,
mechanical solids separation of flushed waste,
gravity settling of flushed waste solids in an appropriately designed basin, or
minimizing feed wastage and spillage.
Lagoon sludge that is removed annually rather than stored long term will:
have more nutrients,
have more odor, and
require more land to properly use the nutrients.
Removal techniques:
Hire a custom applicator.
Mix the sludge and lagoon liquid with a chopper -agitator impeller
pump through large -bore sprinkler irrigation system onto nearby cropland;
and soil incorporate.
Dewater the upper part of lagoon by irrigation onto nearby cropland or
forageland; mix remaining sludge; pump into liquid sludge applicator; haul
and spread onto cropland or forageland; and soil incorporate.
Dewater the upper part of lagoon by irrigation onto nearby cropland or
forageland; dredge sludge from lagoon with dragline or sludge barge; berm
an area beside lagoon to receive the sludge so that liquids can drain back
into lagoon; allow sludge to dewater; haul and spread with manure spreader
onto cropland or forageland; and soil incorporate.
Regardless of the method, you must have the sludge material analyzed for waste
constituents just as you would your lagoon water. The sludge will contain different
nutrient and metal values from the liquid. The application of the sludge to fields will be
limited by these nutrients as well as any previous waste applications to that field and crop
requirement. Waste application rates will be discussed in detail in Chapter I
When removing sludge, you must also pay attention to the liner to prevent damage. Close
attention by the pumper or drag -line operator will ensure that the Iagoon liner remains
intact. If you see soil material or the synthetic liner material being disturbed, you should
stop the activity immediately and not resume until you are sure that the sludge can be
removed without liner injury. If the liner is damaged it must be repaired as soon as
possible.
Sludge removed from the lagoon has a much higher phosphorus and heavy metal content
than liquid. Because of this it should probably be applied to land with low phosphorus
and metal levels, as indicated by a soil test, and incorporated to reduce the chance of
erosion. Note that if the sludge is applied to fields with very high soil -test phosphores, it
should be applied only at rates equal to the crop removal of phosphorus. As with other
wastes, always have your lagoon sludge analyzed for its nutrient value.
The application of sludge will increase the amount of odor at the waste application site.
Extra precaution should be used to observe the wind direction and other conditions which
could increase the concern of neighbors.

'ossible Causes of Lagoon Failure
agoon failures result in the unplanned discharge of wastewater from the structure. Types
,f failures include leakage through the bottom or sides, overtopping, and breach of the
'am. Assuming proper design and construction, the owner has the responsibility for
nsuring structure safety. Items which may lead to lagoon failures include:
Modification of the lagoon structure --- an example is the placement of a pipe
in the dam without proper design and construction. (Consult an expert in
lagoon design before placing any pipes in dams.)
Lagoon liquid levels ---high levels are a safety risk.
Failure to inspect and maintain the dam.
Excess surface water flowing into the lagoon.
Liner integrity --protect from inlet pipe scouring, damage during sludge
removal, or rupture from lowering lagoon liquid level below -groundwater
table.
TOTE: If lagoon water is allowed to overtop the dam, the moving water will soon cause
ullies to form in the dam. Once this damage starts, it can quickly cause a large discharge
f wastewater and possible dam failure.

System Calibration
Information presented in manufacturer's charts are based on average operation
conditions with relatively new equipment. Discharge rates and application rates
change over time as equipment gets older and components wear. In particular,
pump wear tends to reduce operating pressure and flow. With continued use,
nozzle wear results in an increase in the nozzle opening which will increase the
discharge rate while decreasing the wetted diameter.
You should be aware that operating the system differently than assumed in the
design will alter the application rate, diameter of coverage, and subsequently the
application uniformity. For example, operating'the system with excessive pressure
results in smaller droplets, greater potential for drift, and accelerates wear of the
sprinkler nozzle. Clogging of nozzles can result in pressure increase. Plugged
intakes or crystallization of mainlines will reduce operating pressure. Operating
below design pressure greatly reduces the coverage diameter and application
uniformity.
For the above reason, you should calibrate your equipment on a regular basis to
ensure proper application rates and uniformity. Calibration at least once every
three years is recommended. Calibration involves collecting and measuring flow at
several locations in the application area. Any number of containers can be used to
collect flow and determine the application rate. Rain gauges work best because
they already have a graduated scale from which to read the application amount
without having to perform additional calculations. However, pans, plastic buckets,
jars, or anything with a uniform opening and cross-section can be used provided
the liquid collected can be easily transferred to a scaled container for measuring.
For stationary sprinklers, collection containers should be located randomly
throughout the application area at several distances from sprinklers. For traveling
guns, sprinklers should be located along a transect perpendicular to the direction
of pull. Set out collection containers 25 feet apart along the transect on both
sides of the gun cart. You should compute the average application rate for all
nonuniformity of the application. On a windless day, variation between containers
of more than 30 percent is cause for concern. You should contact your irrigation
dealer or technical specialist for assistance.
'Reprinted for Certification Training for OperaWns of Animal Waste Management Systems Manual

INSECT CONTROL CHECKLIST FOR ANIMAL OPERATIONS
Source— Cause SMP's to Minimize Odor WATER CtkVSpectfft- LFYactices
QA
Flush Gutters Accumulation of sohds Wrquah system is designed and operated
sufficiently to remove accumulated Non -Disci PBR±itifin(�
s from gutters as designed.
ova bridging of accumulated solids at
discharge
le
Lagoons and Pits Crusted Solids 0offaintain lagoons, settling basins and
pits where pest breeding is apperent to
minimize the crusting of solids to a depth
of no more than 6-8 Inches over more then
30% of surface.
Excessive Vegetative Decaying vegetation ( 1*19intain vegetative control along banks of
Growth lagoons and other Impoundments to prevent
accumulation of decaying vegetative matter
along water's edge an impoundment's perimeter
(Dry Systems)
Feeders Feed Spillage ( ) Design, operate and maintain feed systems (e.g ,
bunters and troughs) to minimize the accumulation
of decaying wastage.
() Clean up spillage on a routine basis {e.g. 7-10 day
Interval during summer; 15-30 day interval during winter).
Feed Storage Accumulations of feed residues ( I Reduce moisture accumulation within and around
Intrnediate perimeter of feed storage areas by
Insuring drainage away from site and/or providing
edoquate containment te.a., covered bin for
brewer's grain and simllar high moisture grain
products).
( I Inspect for and remove or break up accumulated
solids in filter strips around feed storage as needed.
Animal Holding Areas Accumulations of animal wastes O Eliminate low area that trap moisture along fences
end feed wastage and other locations where waste accumulates and
and disturbance by animals is minimal.
{) Maintain fence rows and filter strips_around animal
holding areas to minimize accumulations of wastes
(i.e. inspect,for and remove or tweak up accumulated
solids as needed).
AMIC--November 11, 1996

Dry Manure Handling AQGUmlrlatrono of animal wastes i I Remove spillage on a routine bases la-g. 7-1 O day
Systems interval during summer; 15-30 days interval during
winter) where manure is loaded for land application
or disposal.
()'Provide for adequate drainage around manure stockpiles.
i 1 Inspect for and remove or break up accumulated wastes
in filter stripes around stockpiles and manure handling
&areas as needed.
The issues checked ( ) pertain to this operation. The landowner{integrator agrees to use sound judgment in applyi;
insect control measures as practical.
f certify the aforementioned insect control Best Management Practices have been reviewed with me.
(l.andown Signature}
For more information contact the Cooperative Extension Service, Department of Entomoiogy, Box 7613, North Carotina State University, Raleigh
27695-7613.
AMIC—November 11, 1996

SWINE FARM WASTE MANAGEMENT ODOR CONTROL CHECKLIST
Source Cause OMP's tg.Minimize Odor Site Specific Practices
Farmstead
Swine production
4Pregetative or wooded buffers;
( R rnmendsd best management
prectr es;
UAISod judgment and common sense
Animal body surfaces
Dirty menure-covered animals
(92<—floors
Floor surfaces
Wet manure -covered floors
<>3^oIa floors;
aterers located over slotted floors;
{ j Feeefpre at fngh end of solid floors;
I era a manure buildup from floors;
ndarfloor ventilation for drying
Manure collection pits
Urine
(AXw<uent manure removal by flush,pit
h ,or scraps
Pardal micorbiai decomposition
( o► ventilation
Ventilation exhaust fens
Volatile gases;
{ j Fan maintenance;
Dust
{ 1 Efficient air movement
Indoor surfaces
Dust
shdawn between groups of animals
(} Feed additives;
(1 Feeder covers;
() Feed delivery downspout extenders to
feeder covers
Flush tanks
Agitation of recycled lagoon
{ j Flush tank covers
liquid whiles tanks are filling
() Extend fill lines to near bottom of
tanks with anti -siphon vents
Flush allays
Agitation during wastewater
i I Underfloor flush with underfloor
eonveyenenee
ventilation
Pit recharge points
Agitation of recycled lagoon
d rechard linos to rear bottom of
liquid while pits are filling
pits with anti -siphon vents
Lift stavons
Agitation during sump tank felling
1) Sump tank covers
and drawdown
Outside drain collection
Agitation during wastewater
I } Box covers
or)unction boxes
conveyance
End of drainpipes at lagoon
Agitation during wastewater
(AXi7tand discharge point of pipes
underneath lagoon liquid level
Lagoon surfaces
Volatile gas emissions
( roper lagoon liquid capacity
&ological mixing
(�r ct lagoon startup procedures
Agitation
[mum surface area -to -volume ratio
1 nimum agitation when pumping
{ 1 Mechanical aeration
{ } Proven biological additives
Irrigation sprinkler nozzles
High pressure agitation
(ifi Yate an dry days with little or no wind
Vllind draft
( p nmum recofwnended operation pressure
{Wump intake near lagoon liquid surface
( ) Pump from second -stage lagoon
AMOC—November 11, 1996

Storage tank or basin Partial microbial decomposition
f ) Bottom or midlevel loading
surface "rung white filling
( ) Tank covers
Agitation when emptying
( ) Basin surface mats of solids
[ 1 Proven biological additives or oxidants
Settling basin surface Parbal cucob,al decomposition
[ ) Extend drainpipe outlets underneath liquid
Mixing while filling
level
Agitation when emptying
[ ) Soma" settled solids regularly
Manure, slurry or sludge Agitauon when spreading
( ) Sod injection of slurry/sludges
spreader outlets Volatile gas emissions
[ ) Wash residual manure from spreader after use
O Proven biological additives or oxidants
Uncovered manure, slurry Volatile gas errussions while drying
( oil ( tion of slurryisludges
or sludge on field surfaces
() incorporation within 43 hours
{) Spread in thin uniform layers for rapid drying
[) Pf2biological aiddltivas or oxidants
Dead animals Carcass decomposition
( for disposition of carcasses
Dead animal disposal Carcass decomposition
I ) Complete covering of carcasses in burial pits
pits
I ) Proper locationlconstruction of disposal pits
Incinerators Incomplete combustion
( ) Secondary stack bumers
Standing water around Improper drainage
( reds and landscape such that water drains
facilities Microbial decomposition of
away from faellities
organic matter
Manure tracked onto public Poorly maintained access roads
Owen access road maintenance
roads from farm access
Additional Information:
Available From:
Swine Manure Management; 0200 Rule(BMP Packet
NCSU-County Extension 0
Swine Production farm Potential Odor Sources and Remedies, EBAE Fact Shoat
NCSU-SAE
Swine Production Facility Manure Management: Pat Recharge --Lagoon Treatment; EBAE 128-88
(NCSU-BAE
Swine Production Facility Manure Management: Underfloor Fuse --Lagoon Treatment; EBAE 129-88
NCSU-BAE
Lagoon Destg and Management for Livestock Manure Treatment and Storage; EBAE 103-83
NCSU-BAE
Calibration of Manure and Wastewater Application Equipment, EBAE Fact Sheet
NCSU-BAE
Controlling Odors from Swine Buildings; PIH-33
(NCSU-Swine Extension
Environmental Aswranc Program: NPPC Manual
NC Pork ProdVcss Assoc
Options for Managing Odor; a report from the Swine Odor Task Force
NCSU Agri Communicanon
Nuisance Concerns in Animal Manure Management. Odors and Ries: PRO107, 1995 Conference Proceedings
Florida Cooperative Extensi
The issues checked ( ) pertain to this operation. The landownerfintegrator agrees to use sound judgment in apply
odor control measures as practical
I certify the aforementioned odor control Best Managment Practices have been reviewed with me.
R. 040g,",
11.andowner Si ature)
AMOC—November 11, 1996

MORTALITY MANAGEMENT METHODS
(check which method(s) are being implemented)
( } Burial three feet beneath the surface of the ground within 24 hours
after knowledge of the death. The burial be at least 300 feet from
any flowing steam or public body of water.
Rendering at a rendering plant licensed under G. S. 106-168.7
( ) Complete incineration
( 1 In the case of dead poultry only, placing in a disposal pit of a size and
design approved by the Department of Agriculture.
( ) Any method which in the professional opinion of the State
Veterinarian would make possible the salvage of part of a dead
animal's value without endangering human or animal health. (Written
approval of the State Veterinarian must be attached)

EMERGENCY ACTION PLAdVQ�� ''�r ECT'°
PHONE NUMBERS IJAN 2 8 1999
DIVISION OF WATER QUALITY (DWQ) Non-Disclang(Eld-0):395-3900
EMERGENCY MANAGEMNET SERVICES (EMS? f910)296-2160
SOIL AND WATER CONSERVATION DISTRICT (SWCD) [phone]
NATURAL RESOURCES CONSERVATION SERVICE (NRCS) [phone]
COOPERATIVE EXTERSION SERVICE (CES) [phone]
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing or running off site. You should not wait until wastes reach surface waters
or leave you property to consider that you have a problem. You should make every
effort to ensure that this does not happen. This plan should be posted in an accessible
location for all employees at the facility. The following are some action items you should
take.
1. Stop the release of wastes. Depending on the situation, this may ore may not be
possible. Suggested responses to some possible problems are listed belwo.
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of darn.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B. Runoff from waste application field -actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that cause the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
D. Leakage from flush systems, houses, solid separators -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed
to flowing leaks -possible action:
a. Dig a small sump or ditch from the embankment to catch all
seepage, put in a submersible pump, and pump back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon

2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what duration?
c. Any damage notes, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours call your DWQ regional office; Phone - -. After
hours, emergency number: 919-733-3942. Your phone call should include: your
name, facility number, telephone number, the details of the incident from item 2
above, the exact location of the facility, the location or direction of movement of
the spill, weather and wind conditions. The corrective measures that have been.
under taken, and the seriousness of the sitution. - .., - - -
b. If spill leaves property or enters surface waters, call local EMS phone number.
c. Instruct EMS to contact local Helath Department.
d. Contact CEs, phone number - , local SWCD office phone number - -, and local
NRCS office for advice/technical assistance phone number - -.
4. If none of the above works call 911 or the Sheriff's Department and explain you
problem.to them and ask the person to contact the proper agencies for you.
5. Contact the contractor of your choice to begin repair or problem to minimize off -
site damage.
a. Contractors Name:
b. Contractors Address
c. Contractors Phone:
6. Contact the technical specialist who certified the lagoon (NRCS, Consulting
Engineer, etc.)
a. Name: n3RC�S
b. Phone: 9to ML-- 41
7. Implement procedures as advised by DWQ and technical assistance agencies to
rectify the damage, repair the system, and reassess the waste managment plan to
keep problems with release of wastes from happening again.
E

Z
PI
J 0 N E S
C 0 U N T Y
,\♦ sf p QOYrOtl •�
N
bee
MI
Mink was one of the
earers, but as Lash
mg -haired puts be(
he color of the fur
ark and glossy on t
re raised on game
hey are 1 % to 2 feet h
port legs and a long t
ight, mostly on small
hey nest in burrows in
er stumps or in hollow

z
%• 7_ „
J 0 N E S
C 0 U N T Y
,I• ., m CO..W--
�{ J
0 0 0 0 a-MININ-0 12 R - -
N
bee
Mi
Mink was one of the
bearers, but as fash
ong-haired pelts bec
the color of the fur
Lark and glossy on t
;re raised on game
they are 1 % to 2 feet I+
;port legs and a long t
light, mostly on small
rhey nest in burrows in
ier stumps or in hollow

,011 n^^.AA ^,A /� /I ^^A^I, A^.^ j A^AIj .N^r1 l..I�I+, I�1 .^ h/,;I�
**fttike 111ttteltft.
The State of North Carolina
Department of Environment, Health and Natural Resources
hereby certifies that
Rocky M. Mobley
bas met tine rwomnmt9 fir certification established by the Depmunent
pursuant to North Carolina General 5tatuto 143-215.74E as an
Animal Waste Management System Operator
DMPjMR
Division of Water Quality
19112 August 15, 1996
CERTOCATENUMBER DATEISSUED

RECEIVED SEp 2 8 1998
2108 H.allsiflie Road
Beulnvi?le. N(.' 2$5 IS
September 21, 1998
Briatl kyreltn
DEIINit
Ditislon of Water Quality
127 Cardinal Drive Ex,.
Wilmington, NC 28403
Dear k1r. Wrenn-
T116s letter is its respOtlSe tO the Nt Ot1Ce of for the G:7rJa11d 13rpc.lf F&IFT11
i t`N: j 1.._�71i1. 1 feel that the Notice o(Deficiency is Inappropriate in this situation and rqucst
that it be removed Fight the records. As stated clurilig the intpeetitm, the ingaon %Nblch you
refrc►t7ed as hoeing ingu icient freeboArd has bcesi clonoed according to N1tt<;S spccifications and
no lrmger reouires operation car rnaitttetlancc. TJvs closure has been approved by the local MRCS
ufke and you may contact Harold Jones its that office for futiiler iiditnnatic►rt. Enclosed is
dr, cutnelitation frorn MRCS standard.% which explains o�hmer :options in Iagooti clowres. In
addition, the f'ekcue: crap ti ill be re -planted as plannt!d this trill. 11te field it(it 5%wd in the waste
managi•m�nt plan is being add<d. Pfiot to irrigation oftln<; �rt0d, the technical speciali% advised
me to irri cttC on this field and said that the plan would be revised W inrJude this field a.S wor5 as
possible. Proper impatiou vas Conducted to meet MRCS application rates. However_ irrigation
,ri!! wise on this Bold until 1 have rec~i�e ed a revised wastc nlatiagentent plats.
In addition, I would like the in.Vection report revised or amended to show the actual
situation. Curnments S; 9, and 12 ulr.ould be rejnvN-cd and the questions tuarked `rid' due to the
closure of (his lagpon. ti�ott!?r lit ?" 3 COW 1' lk rerj_10v� d �i; jpPECation dAtes of fegeue have
been ubsatved and all waste and soil samples are up-to-date. The earliest application to fescmc.
,vas :-%ugust 24, Or application dates listed in the waste .2tanagenlent plan are Sept -Nov, FeWim-
Ni RCS spccifi(mions allow irrigation 30 days prior to plandue or breaki ljg dormancy which ► ould
snake anv svplication alter .Augus--t t acceptable. The heist soils aaalysis was completed in
l*he iatesi waste artalisis was completed June 21, 1998. Neither: sanrplu)g is
overdae. Question 22 sh.ottld also be marked 'No" when their. comments are removed.
A.u- ;;Lated rm ier, actions are being taken to improve the crops and general rn.�rnagement on
the, barn,. 1 feel, however, that a Notice of Deficiency is not warranted bi this situation_ I would
r ppieciam, if you could address the issues that I have IRqe`l. and rtzpond to we with your decision.
'thank you for your tithe and WTISi[ CTR ion.
Sincerc.v,
Garland Brock

P.G
NA7',- R.AL RESOURCES CONEER -A i I0,: SERVICE
I TERM ST NDA& D
fo r
CLOSLR:_ OF A3ANaO070 WAOT! U MA T LAC,CO S
AND
W,iSTY w T OR -AGE PQLN-D5
(N o. )
00993
Thz and lvuw:
frcm T r m-r m:a; :_ aq :$ and - i 3zze
S C mge Pot'.CLs ch"n, 2ve ,o ioage; iP. use Ior the.
POSE
'The purpostafl#,is 4r]s^"r3ii 7r(tcactistc
Pfatec.'he 3l ashy ai 3ca .racer arc
zvw=d =mr n=cu= and rC SG ',lard the
Public henv..
CON-DITIONS ` .HERE PRACTICE
ICE
aPPLUS
J � S rzlC ce aopiir_: to Cull.; Zi '5100 Truacmi: c
Lzgccns and Wa,,e S.crage Ponds dl..t rfe ao
Ica_:: 1;Vd for their ari'_? iai i-i.e read p-ur?ase.
rpiT-V 101A
Qhjrr!ive
TIZ ob!er:ilve is to mr-�ove t ws ,5 rrla t%nais -0
ma 1 :i'�I;t c C:� is �r r iCaGid uLlr! s
llzc=.1'S7.mc-una prior Zo,.:Qsu.=,
Water Quality Tenting
1qo Sr eti: t watC' :� S3 I't tC:11�7� Mil bt r;!Gt 1-2-"
Ra�slaval of Intlow DCvicta
-,:sad :-c caave•., cri•-ai •va sic Lazo t -c
or sm:zge pond s .nil be rtmcved.
493-!
wai;I%VnVj
�]! aGanc�cre::d>cc;.s cr •.i-: cL' ST-�};3.� r0!i .
M5t brz:nCz L.• lhaz 2.v? as
e;lIC:3_; ku-n- :t o_ - Iw.- or rjam, si'i-itd i'x7. a
primps'. spillway :-,Id an spL,,jz
%r,^snw:�. _n prct:.ce ;ran a 73 (Pozdsi,
E-cavated nits
i'cr :hZt Ncr� ps?'r;ouslY Useci
Ivuste it n^,c 1C ial,O s ra: , :'as<e saraae rent;;
ha: 7--e ;O be a!! F--:.Sonabf�! .Eot--a" i2'us-,
= imadc 7.4 agiirzce --_ad
rta=.ert.s_ ;;` the �cc* :mil � c ::Ie 'i Qaoh,�s[n:c:are
t: c dime cf cbszre alzd
%Mll au Gov t5 rnovrn, aquipm=[r it Host ue
aecer rice �Y'.e soil nablry fu:- ear± moving
zc i:prrcar'For r;art arc not ro
C= Sawn: she zk,�: �4:� ��]''J't'S �t;ca-•rea �a -c
:;e Lei«v t; e tracer Lcie at to rime of c!05liriy_
1II de ?a.:Pcalsrii calrG ac ;he m? of ciasu:e rrav_
roc eFc__:l a = -=w- l eeo6 of mire r ::-= Cne
(i) So
0 wam. xw-;zr %,;iU. be ariaiyz d amd a7p'irti .s
ci%Cs u a oIIi. '.w lateen oaS--d onrRe'�aila'-1G xid
;w :ve:�tiasl (' s E.) ?Cr niTra¢e:•t N-
Or:. ='� 5'lf'�nC :3 :Ci't7__ tied ills Giir.G::134 �e
ot3Li4Q CE :SM2 L�t Z a L eSn
Dcrd. of Lie j-t mlt; __ 3i. , - — --
�Crnserv�c',an;,r-.=.•rity:n:tu:..:evi-�rii^era�itzily.�ic•�:�-•a
i niztis `.:�=,rd. ;r�.:aLht Yalu-� �-avr� C_,�r.•,a.�c� :�*--z i
-...^ MUX :Is: _93.a�[,.�-'.a �•t•Ccan�tc_irv'iV
Y

p.3
9 3M
En-ankmenr Structures
if a laEraan/sL.1 c.-ure :S co Dz the i qu-.d
ut -,z be grimgeC Cut --nd :.he
r;.a:e ai sc �r5e ana�ie e arc m"u I,e
rLidc :c rc:aoveail. �yasFe mat.-ials p6or to
For m
�i�1^•.oy.C1L` �Ctt1C �r Lo t"
4r��..�...
1CWcr:a,ble c.icC'] i[ L'{L ez m._d=
remc "!e aI( C7e Zmaom, )f
iavCCnisssc^arw is above r.1e waret :abie ; .e
.itre of closure and tivi!; augpt:rt;cr moving
zquipmeu; it may~t he sm—ped. A qualified
r?c.-s.^x l spec:atlst mus: dererrrtfue he —i,
. C btlirlr Itcr a:arth rno-, in2 a it S�fP.t :[. For
'5.11corjS 5'tr_C;sr,-S dtai are aC: to bz sc.^spt*d �d
tnase wiU, baticros doc_:r:e:t & ro be haul - a
rrarer whit at the like of eiQSurt, the of
'`a iraxd— %vasm material I.=.2LIirta n Cht:
lzgmnirmac;ure at the time- OfClasure s:nw�, mor
= -d 3 nia`irr:um det_ m of mR re than one rI;
In
The 1vaSt.'. will be crn y"-d and to
craps at ignmomi:vans buk na NASA WIA
E%pectatiau (P y2-) for r. rYn-y—n (iv).
L�:IfCCnd? i for uze w a freso. '.oaEC: pand• the
rcv!remeatrs tinder " Spiihvays" 5e-,Iron a rail
s`..anraid sIftU be met,
The Wwfum nt may be:
? ) ate:hed so that ii will Zo lcnger 4rao=i
[illttid. or 2 lei inset and al:mved to ii? %,itll
Sesh '.4'atcr tar use : a �esli Nzler,660: -- "
IF L,e is b1zaclie-, tLe je opeT Sri
bottcm of &. -. breach shall be stable for the sc3
maze--U.i involved, bui rite side slopes shall be nc
sf.�.?er _h3a 3:1,
Ageadon
,1!I di.=rbe:i areas ;hail he veg!!=ad in
acCar&JICn with T�C:njj;cra Guice Standard =-+Z.
Cr:tie :.i, A= Trea=ent.
C0ftSIDEI-ATIO�°5
The rropc- rc: aE C= Qq:!Z- ,ics =d and
: :en :ior, of pcilu�:rt disc.�ar?,� :a s- -- ce
v,aters is the m ;;orisibii;r. of :t c clvner.
PLA-NS AYD Sc?£CIMATIONi
2--.d Sp=:. cad,;r,S for ^,.-an!ro c: abzndo:!sz
.:icew ut i, ant Agee s er.G wzQ a t-flmg-- yowds
z aH t: in k2ep-, Mth 4N5 su1f1 a: and Chz"
:h
I.4 the Sv Bte srec e: t Iaaacn ar Nvasre Stomgc
Pa. d being r:ar.re xd rc a NO non: PON is
require;; w awn Const ra.im Pr wAt Ct:sNd
" 13 (FO"[ds), Ite oi-^S Mad sWeCizze .orls «u
also be ia lei?lag owith cire of t:.:�
sraudard.
OPF'.R .TION AND :4i�d:�ITC V� \ir ti
prop eriv_ decorrix siss ored Ire~r.' Tnat
l- ccr ,)r :tone :oral should requirt iirle
;;a-s i;e_, convene, tc =cthztr u5e, such as a
fnsh z'in-i::r poed, eper.Arica and:nai ire c::.nii
be :B :. zorr'.. ,rich '.V1C,1 tie rot"- #s se- f6 li La
Canst. ratu;n Practice Srzmdi.ra 373 (Pans).
�� : NC
WENT. _... OF

�n.n1�31 �•Vasfe Storage Pond and Lay000ll Closl.>rc
(PIC-Ise [vpc: or ptFn[ all inrornx)[ion That do's not require a si•2nantre)
General Information:
i\iame of Farm: N /R
Facili[y vo:LNJA-
Ow•ner(s) vame:��431gn�
Mailing Address: .—Phone
Oneration Description (remaining onimals only):
C1 PleaSC CheC\ 111i5 OOX if thC:C Mil be no anima.is on this farm after Ingoon closure. [f there •.viil still be animals on [; e site
atte: lagoon closure. please provide [tie foilowine information on the animals that ;vIII1 re.nain-
Oueration Description:
T}Pe of SwIlte NO. of .irtintais
'J- Wean 10 F=!rr .
Feeder to Finish
Farrow to Wean 1
Z CT
:.t Farrow to Feder
.J Farrow to Finish
T-rpe of?0td1r: NO. of Anin:als TIvPe of C.n:1e
f aver' _i Dair•'
Pulle!s J I3tei
No. Or .a nill-'eis
Orher Type of Livesrock. A"Y121ber of .Ajl irna[s:
Will the farfn maintain a pumber of animals afeater than the 2H .0217 thresholc P, Y4s V- \o `1
Will other lagoons be in operation at this faun after this one closes? Yes do D
How many lagoons axe left in use on thi's farm?: l
(tvatne) o s! Vib-ITi'K 6k of the Water Quality Section's staff in the Division
of Water Qualitv's Regional Ofrice (see map on bac.Q
was contacted on /0_S(date) for notification of the pending closure of this pond of laQoon-
This notification was at least 24 hours prior to the start of closure which began on (datej.
I verify that the above information is correct and complete. I have followed a closure plan which meets
all MRCS specifications and criteria- I realize that I will be subject to enforcement action per .A-aicle 21
of the North Carolina General Statutes if I fail to properly close out the lagoon.
Name of Land Owner (Please Print):
Signature: Date:
The facility has followed a closure plan which meets all requirements set forth in the MRCS Technical
Guide Standard 998. The following items.were completed by the owner and verified by me- all waste
liquids and sludges have been removed and Viand applied at agronomic rate, all input pipes have been
removed, all slopes have been stabilized as necessary. and veg�eeetaattion established on all disturbed areas.
Name of Technical Specialist (Please Print): -1Ci � a ' Dne-5
Affiliation: 5LA - els e �1cDf\) SeCku Ce,
Address (Agency): B J'7 ez,,a 15 Oki�t � 1�C Phonz o.: '
Signature: Date:_
! erurn ti4tthtn days to[ o�tirn7 cumplettan of :tntrnat �r Aterstoravc porict or lagoon c osure to:
,N. C_ Division Ot' Water -Quality- l ater Quality Section
4 CompIianc:e Group
P.U. Box 29535
aale-':O. NC 27626-0-51:
PLC - E i iv - . !
T

State of North Carolina
Department of Environment,
Health and Natural Resources
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
November 13, 1996
Freddie Halso
Freddie Halso Farm
200 Eneas Lanier Rd
Chinquapin NC 28521
SUBJECT: Operator In Charge Designation
Facility: Freddie Halso Farm
Facility ID#: 31-378
Duplin County
Dear Mr. Halso:
Senate Bill 1217, An Act to Implement Recommendations of the Blue Ribbon Study
Commission on Agricultural Waste, enacted by the 1996 North Carolina General Assembly,
requires a certified operator for each animal waste management system that serves 250 or more
swine by January 1, 1997. The owner of each animal waste management system must submit a
designation form to the Technical Assistance and Certification Group which designates an
Operator in Charge and is countersigned by the certified operator. The enclosed form must be
submitted by January 1, 1997 for all facilities in operation as of that date. Failure to designate a
certified operator for your animal waste management system is a violation of 15A NCAC 2H
.0224 and may result in the assessment of a civil penalty.
If you have questions concerning operator training or examinations for certification, please
contact your local North Carolina Cooperative Extension Service agent or our office.
Examinations have been offered on an on -going basis in many counties throughout the state for
the past several months and will continue to be offered through December 31, 1996.
Thank you for your cooperation. If you have any questions concerning this requirement please
call Beth Buffington or Barry Huneycutt of our staff at 91gn33-0026.
Sincerely,
Preston Howard, Jr., erector
Division of Water Quality
Enclosure
cc: Wilmington Regional Office
Water Quality Files
P.O. Box 27687, W W.
Raleigh, North Carolina 27611-7687 � An Equal Opportunity/Affirmative Action Employer
Voice 919-715-4100 50% recycled/ 1046 }post -consumer paper

nr
REGISTRATION FORM FOR ANIMAL FEEDLOT OPERATION. r~ * D
Department of Environment, Health and Natural Resources NO�JJS3 l
Division of Environmental Management v
Water Quality Section
If the animal waste management system for your feedlot opt atiar'i"O,�2n
is designed to serve more than or equal to 100 head of cat-, 75
horses, 250 swine, 1,000 sheep, or 30,000 birds that are se eoz7ls�
by a liquid waste system, then this form must be filled out and
mailed by December 31, 1993 pursuant to 15A NCAC 2H.0217 (c) in
order to be deemed permitted by DEM. Please print clearly. ,7,3 4 56
4
Farm Name: Freddie Halso
boo n! HS L n E NOV 1993 0
Chinquapin, NC 28521 r :VATER QUAILITY
Duplin County 919-285-4599 Planning Branc°
Owner(s) Name: ca / r 4<-0 Cam'
Manager(s) Name: C l
Lessee Name:
Farm Location (Be as specific as possible: road names,
di ection, milepost, tc.):o--
..,...
2
Latitude/Longitude if known: QBSP # 24-028-02-16
Design capacity of animal waste management system (Number and
type of confined animals): 4 sowS
Average animal population'on the farm (Number and type of
animal(s) raised),: 60Y IQ ivs iec70 AfurSf!jrX'
Year Production Began: b ASCS Tract No.:
Type of Waste Management System Used: d,,,,,0,<,
Acres Available for Land Appli tion of aste: 30 O a<4�
f7
Zr
owner(s) Signature(s): r Date:
Date:
(Jane Mitchell, serviceman)
3 (- 3-48

State of North Carolina
Department of Environment,
Health and Natural Resources
Division of Environmental Management
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
A. Preston Howard; Jr., P.E., Director
December 9, 1993
Freddie Halso
200 Eneas Lanier
Chinquapin NC 28521
Dear Mr. Halso:
This is to inform you that your completed registration form required by the recently
modified nondischarge rule has been received by the Division of Environmental Management
(DEM), Water Quality Section.
On December 10, 1992 the Environmental Management Commission adopted a water
quality rule which governs animal waste management systems. The goal of the rule is for
animal operations to be managed such that animal waste is not discharged to surface waters
of the state. The rule allows animal waste systems to be "deemed permitted" if certain
minimum criteria are met (15A NCAC 2H .0217). By submitting this registration you have
met one of the criteria for being deemed permitted.
We would like to remind you that existing feedlots which meet the size thresholds
listed in the rule, and any new or expanded feedlots constructed between February 1, 1993
and December 31, 1993 must submit a signed certification form to DEM by December 31,
1997. New or expanded feedlots constructed after December 31, 1993 must obtain signed
certification before animals are stocked on the farm. Certification of an approved animal
waste management plan can be obtained after the Soil and Water Conservation Commission
adopts rules later this year. I
We appreciate you providing us with this information. If you have any question about
the new nondischarge rule, please contact David Harding at [phone].
Sincerely,
v✓ t
Steve Tedder, Chief
Water Quality Section
P.O. Box 29535, Rdeigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer W% recycled/ 10% post -consumer paper

.
�
m
=

U 42 1 NP-4+00RO C.17

R

.sa
i'i
�`+
�:
r•. �
�-
r
.x�
••c-
i
i-
�:r�,
.x;�
,�-

,,
-;
L �A� � r �,
Y � s
% �
_� � � ,�
\��•;: �
�-
�,,+ �y -, ..- ,
F.
�•.
`\� � ..
`- �'

i f '' ' I / /
V %� ' � 1 \
-� �i-_ I� 4.� 1, A _ �
:_ 1 � �:
�, � , {
T . / �` i ..
%�� 7 .A �� - �� � /�� �
� � � y 't 1 � � \r_ f/j�
/�/
�� J A Y
�� +��,� a " ���
t � v'
-- \�
_ _
__. �._ ,
�.; � —_'

6�1

+j. HAN +tSPU :�7-7�7.: