310311_HISTORICAL_20171231

BARWICK AG SERVICES, LLC
103 Country Club Circle
Clinton, NC 28328
910-385-1000
June 25, 2016
North Carolina Division of Aquifer Protection
Attn: Mr. Kevin Rowland
127 Cardinal Drive Extension
Wilmington, NC 28405-2845
Dear Kevin,
Please find enclosed an updated Waste Utilization Plan for the Heber Raynor Farm (31-311).
Acreages have changed on tract 7656 due to underground pipe being installed.
If you need further information regarding this please call me at 910 385-1000. Thank you for
your attention to this matter.
Sincerely,
(2'714-2-�
Curtis Barwick
RECEIVEDIDCDENR/M
JUN 2 9`2016
Water Quality Regional
operations So ti Office
Wilmington Reg

e
WASTE UTILIZATION PLAN
Monday, May 06, 2013 tAPP4_rgT ' 3 - 2P-1 fo
Producer: Heber Raynor
Farm Name: Cedar Fork Farms 31-111
386 Edmond Brinson Rd.
Beulaville,NC 28518
Telephone # : [phone]
Type of Operation : Wean to Feeder Swine
Number of Animals: 3840 pigs design capacity
Application Method: Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface and/or groundwater. The plant nutrients in the animal waste should be
used to reduce the amount of commercial fertilizer required for the crops in the fields where
waste is to be applied. This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil tests are strongly
encouraged so that all plant nutrients can be balanced for realistic yields of the crop to be
grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
contents of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and avaialable water holding capacities. Normally waste shall not be applied to
land eroding at greater than 5 tons per acre per year. With special pre -cautions, waste may
be applied to land eroding at up to 10 tons per acre per year. Do not apply waste on
saturated soils, when it is raining, or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed under DEM regulations. Wind
conditions should also be considered to avoid drift and downwind odor problems. To
maximize the value of the nutrients for crop production and to reduce the potential for
pollution, the waste should be applied to a growing crop or applied to bare ground not more
than 30 days prior to planting. Injecting the waste or disking will conserve nutrients and
reduce odor problems. This plan is based on waste application through irrigation for this is
the manner in which you have chosen to apply your waste. If you choose to inject the waste
in the future, you need to revise this plan. Nutrient levels for injecting waste and irrigating
waste are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. Acreage requirements should be based on the waste analysis report
from your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for ananlysis. This waste
utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H.0217 adopted by the Environmental Management Commission.
Page 1 of 9

AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
3840 pigs X .4 tons wastelpigslyear = 1536 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
3840 pigs X .48 Ibs PAN/pigs/year = 1843.2 PAN/year
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on the crop to be grown,
soil type and suface application.
TABLE 1 : ACRES OWNED BY PRODUCER
TRACT FIELD SOIL TYPE &CLASS- CROP YIELD LBS AW COMM ACRES LBS AW APPLIC.
DETERMINING PHASE CODE NIACRE NIACRE USED TIME
6662
1
FORESTON ALL
C
120
138
0
13.54
1868.52
MAR-JUN
6662
1
FORESTON ALL
W
55
114.95
01
13.54
1556.42
5EP-APR
6662
" 1
FORESTON ALL
SBJ
34
132.94
0
13.54
1600.01
APR SEP 15
6662
1
FORESTON ALL
WA
11
50
0
13.54
677
SEP-ARP
7656
2
FORESTON ALL
C
1201-
138
0;
3.38
466.44
MAR-JUN
F 7656
2
FORESTON ALL
W
55
115.0051
01
3.38
388.717
SEP-APR
7656
2
FORESTON ALL
SB
341
132.941_
01
3.38
449.337
APR-SEP 15
7656
2
FORESTON ALL
WA
501
0
3.38
169
SEP-ARP
7656
" 3
FORESTON ALL
c
I 120E
1381
01
5.26
725.881
MAR-JUN
7656
' 3
FORESTON ALL
W
55
115.0051
01
5.26
604.9261
SEP-APR
7656
3
FORESTON ALL
I SB_1
341
132,941
01
5.26
699.2641APR-SEP
15
7655 �"
7656
3
5
FORESTON ALL
FORESTON ALL d�
WA
C _
1
120i
501
_ 138'
Dj
D
5.26
1.95
263'
269,11
SEP-ARP
MAR-JUN
7656
5
FORESTON ALL
J W
551
115.005
01
1.95
224.261
SEP-APR
7656
5
FORESTON ALL J
SB
_ 341
132.94
01
1.951
259.233
APR-SEP 15
7656��
5
FORESTON ALL
WA
1
- 501
0:
1.95
97.5,
SEP-ARP
TOTALS: 5259.30
Indicates that this field is being overseeded (i.e. interplanted) or winter annuals follow
summer annuals.
" Indicates a Crop Rotation
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N
requirments. Beginning in 1996 the Coastal Zone Management Act will require farmers in
some eastern counties of NC to have a nutrient management plan that addresses all
nutrients. This plan only addresses Nitrogen.
Page 2 of 9

TABLE 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land. See required specifications 2.)
There are no Acres Leased
Indicates that this field is being overseeded (i.e. interplanted) or winter annuals follow
summer annuals.
* Indicates a Crop Rotation
* Acreage figures may exceed total acreage in field due to overseeding.
**Lbs AW N (animal waste nitrogen) equals total required nitrogen less any commercial
nitrogen (COMM N) supplied.
The following legend explains the crop codes used in TABLES 1 and 2 above:
CROP CODE CROP UNITS LBS NIUNIT
C
CORN
BUSHELS I 1.25
SB
SOYBEANS
BUSHELS 4
W
WHEAT
WA
WINTER ANNUALS
AC 100
Page 3 of 9

TOTALS FROM TABLES 1 AND 2
ACRES LBS AW
N USED
TABLE 1 24.13 5,2
TOTALS: E 24.13 5,259
AMOUNT OF N PRODUCED: 1,843
—BALANCE -3,416
' This number must be less than or equal to 0 in order to fully utilize the animal waste N
Produced.
Acres show in each of the preceeding tables are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter
areas not receiving full application rates due to equipment limitations. Actual total acres in
the fields listed may, and most likely will be, more than the acres shown in the tables.
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of
sludge at agronomic rates. The sludge will be nurturient rich and will require precautionary
measures to prevent over application of nutrients or other elements. Your production facility
will produce approximately 291.84 pounds of plant available nitrogen (PAN) per year in the
sludge that will need to be removed on a periodic basis. This figure is PAN when
broadcasting the sludge. Please be aware that additional acres of land, as well special
equipment, may be needed when you remove this sludge.
See the attached map showing the fields to be used for the utilization of waste water.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the soil at the time of
irrigation such that runoff or ponding occurs. This rate is limited by initial soil moisture
content, soil structure, soil texture, water droplet size, and organic solids. The application
amount should not exceed the available water holding capacity of the soil at the time of
irrigation nor should the plant available nitrogen applied exceed the nitrogen needs of the
crop.
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every 5.92 months. In no instance should the volume of
waste being stored in your structure be within 1.6 feet of the top of the dike.
If surface irrigation is the method of land application for this plan, it is the responsiblity of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in Tables 1 and 2. Failure to apply the recommended rates and
amounts of Nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application rates and amounts.
APPLICATION APPLICATION
TRACT FIELD SOIL TYPE CROP RATE (inlhr) AMT (inches)
6662
FORESTON ALL
WA
T 0,50
'1
6662
FORESTON ALL
w
0.50
"1
6662
'k
FORESTON ALL
SB
0.50
'1
6662
FORESTON ALL
C
0,50
"1
7656
-2, -3, -5
FORESTON ALL
WA
0.50
'1
7656
•2,'3, `5
FORESTON ALL
w
0.50
`1
7656
'2,03,'5
FORESTON ALL
SB
0.50 u
'1
7656
`2,03, 45
FORESTON ALL
C
0.50
'1
' This is the maximum application amount allowed for the soil assuming the amount of
nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Page 4 of 9

NARRATIVE OF OPERATION
Acreages for Tract 6662 are from a previous design. Acreages for Tract 7656 are from an
irrigation design completed by Geg Swain on 3-28-16.
Page 5 of 9

PLANS & SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited. Illegal discharges are subject
to assessment of civil penalties of $10,000 per day by the Division of Water Quality for every
day the discharge continues.
2. The Field Office must have documentation in the design folder that the producer either
owns or has long term access to adequate land to properly dispose of waste. If the producer
does not own adequate land to properly dispose of waste, he shall provide NRCS with a copy
of a written agreement with a landowner who is within a reasonable proximity, allowing
him/her the use of the land for waste application for the life expectancy of the production
facility. It is the responsibility of the owner of the facility to secure an update of the Waste
Utilization Plan when there is a change in the operation, increase in the number of animals,
method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for realistic
crop yields based on soil type, available moisture, historical data, climate conditions, and
level of management, unless there are regulations that restrict the rate of application for
other nutrients.
4. Animal waste may be applied to land that has a Resource Management System (RMS) or
an Alternative Conservation System (ACS). If an ACS is used the soil loss shall be no
greater than 10 tons per acre per year and appropriate filter strips will be used where runoff
leaves the field. These filter strips will be in addition to "Buffers" required by DEM. (See
FOTG Stantard 393 - Filter Strips and Standard 390 Interim Riparian Forest Buffers).
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland, the
waste may be broadcast provided the application does not occur during a season prone to
flooding. (See "Weather and Climate in North Carolina" in the NRCS Technical Reference -
Environment file for guidance.)
"7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
runoff does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control conditions
conducive to odor or flies and to provide uniformity of application.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with
a high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste shall
not be applied more than 30 days prior to planting of a crop on bare soil.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following:
the outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and from anv perennial stream or river (other that an irriaation ditch or canal. Animal waste
Page 6of9

other than swine waste from facilities sited on or after October 1, 1995), shall not be applied
closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal Waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landownwer.
14. Waste shall be applied in a manner not to reach other property and public right - of ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted croplands
provided they have been approved as a land application site by a "technical specialist".
Animal waste should not be applied on grassed waterways that discharge directly into water
courses, except when applied at agronomic rates and the application causes no runoff or
drift from the site.
*16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc.,
shall not be discharged into the animal waste management system.
*17. A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). If needed, special vegetation shall be
provided for these areas and shall be fenced, as necessary, to protect the vegetation.
Vegetation such as trees, shrubs, and other woody species, etc. are limited to areas where
considered appropriate. Lagoon areas should be kept mowed and accessible. Lagoon berms
and structures should be inspected regularly for evidence of erosion, leakage or discharge.
*18. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
*19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks, and spills. A regular maintenance checklist should be
kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops for
direct human consumption. However, if animal waste, is used on crops for direct human
consumption, it should only be applied as a preemergence with no other applications of
animal waste during the crop season.
*21. Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to mark
the maximum storage volume fpr waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least
annually at crop sites where waste products are applied. Nitrogen shall be the rate -
determining element. Zinc and copper'levels in the soils shall be monitored and alternative
crop sites shall be used when these metals approach excessive levels. pH shall be adjusted
for optimum crop production amd maintained. Soil and waste analysis records shall be kept
for five (5) years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina Department of
Agriculture regulations.
* Liquid Systems
Page 7 of 9

May 21 2016 05i5Fm HP Fax Page 2
NAME OF FARM: Cedar Fork Farms 31-111
OWNER I MANAGER AGREEMENT
(via) understand and will follow and implement the specifications and the operation and
maintenance preoedures estallshed in the approved animal waste utilization plant for the farm
named above, I (we) know that any expansion to the existing design capacity of the waste
treatment and/or storage system or construction of new facilities will require a new utilization
plan and a new Certification to be submitted to DEM before the new animals are stocked_
(%va) understand that I must own or have acres to equipment, primarily Irrigation equipment,
to land apply the animal waste described in this waste utilization plan. This equipment must
be available at the appropriate pum plug time such that'no discharge occurs from the lagoon
in a 25-year 1-day storm event. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates that no runoff occurs.
NAME OF FACILITY OWNER: Heber Raynor
SIGNATURE- DATE:
NAME OF MANAGER (if dif d*nt from owner): e--Yl w a
pled a print
SIGNATURE: DATE:
NAME OF TECHNICAL SPECIALIST; Curtis Barwick
AFFILIATION: Barwick Ag Services
ADDRESS (AGENCY): 103 Country Club CImile
Clinton, NC 28328
(910)385-1R a
SIGNATURE: DATE:�'�fr�G
Page 9of9

4
C-1 4
�4
.5r
FA
raw
1.
dV
Ll
Fos.
5

PULL # WIDTH
LENGTH
ACRES
1 234
575
3.09
2 234
575
3.09
3 234
513
P-76
4 234
682
3.66
5 1i7
354 1
0.94
-
TEITAL PULLS = 5
TOTAL ACRES = M4
r �E)0D6
90% E)(TERI[iR PULLS
FOR 0260
MODS E
70% INTERIOR PULLS
FOR 0260
ACRES = WIDTH X LENGTH / 43,560
�0318
ED
5
� r
� r r
mom
mm
i
i
J �
i
pi
l�
TITLE: HUNTER FARM
AGRIMENT SERVICES INC.
wl3m m"Ar'm'NT coNsuLTANTs FARMER: CHARLES HUNTER
P.O. BOX xoss
Haves, NC285xa BY. JONTHAN MILDER CK. BY. GENO KENNEDY
(252) sae--264e
DATE: 5-21-99 CODES:T--6662 FARM #:31-111
IMAM� rem
SC ALE: 1" = 400' DRAWING #: 1 OF 1

y 555 IPull �� ti'
° — — — — — —Pull _ _.._. _ _ 545'-. Full ♦�
J w
OUO Pull }
�* f
M ,

CALCULATED EFFECTIVE WETTED ACREAGE (NEW SPRAYFIELDS) FOR
CEDAR FORK FARM, Mr. Heber Raynor
PULL
TYPE
PULL LENGTH
EFFECT. WIDTH
MIDDLE ACRES
START
END
TOTAL
6
N75+
500.0
158.0
1.81
0.14
0.00
1.95
7
NE75
545.0
183.6
2.30
0.31
0.00
2.61
8
INE75
555.0
183.6
2.34
0.31
0.00
2.65
9
NE75
335.0
183.6
1.41
0.31
0.00
1.72
10
EE70
320.0
183.6
1.35
0.31
0.00
1.66
TOTAL WETTED ACREAGE:
10.59
!VOTES:
1. DIMENSIONS BASED ON ESTIMATED SCALED MAP FROM DUPLIN CO. GIS
2. WETTED ACREAGE FOR START ENDS AND STOP ENDS ARE TAKEN FROM CAWMP WETTED ACREAGE
3. ALL CALCULATIONS BASED ON 0.87" RING IN SR100 GUN AND CALIBRATED WETTED DIA 2401
.
180' LANE SPACING.
r 4. EFFECTIVE SPRAY WIDTHS BASED ON NEW FIELD DESIGN STANDARDS.
15. OPERATOR MUST TAKE PRECAUTIONS AND OBSERVE IRRIGATION EVENTS TO PREVENT RUNOFF FROM
OVERAPPLICATION, SPRAY DRIFT, ETC. APPLICATION SHOULD NOT OCCUR IN OVER 5 mph WINDS
OR ON FROZEN OR SATURATED SOILS.
6. OPERATOR MUST VERIFY REQUIRED SETBACKS AND MARK LANES TO ENSURE ACCURATE APPLICATION.
7. SYSTEM SHOULD BE CALIBRATED AND OPERATED TO DESIGN SPECIFICATIONS, OR DESIGN MUST BE
MODIFIED TO ACCOMMODATE CHANGES.
R. Gregory Swain, P.E.
305 Wendover Ln
Wilmington, NC 28411
[phone]