310305_HISTORICAL_20171231

NORTH CAROLINA
Department of Environmental Qual

` 0 Division of Water Resources
❑ Division of Soil and Water Conservation
❑ Other Agency
Facility Number. 310305 Facility Status: Active
Inpsection Type: Compliance Inspection
Permit- AWS310305
Inactive Or Closed Date:
Reason for Visit: Rouune County. DupOn Region:
Date of Visit: 06119/2014 Entry Time. 09:30 am Exit Time: 10:30 am Incident #
Farm Name:
BOO Farm
Owner.
John C Byrd
Mailing Address:
1279 Bowden Rd
Owner Email:
Phone:
Warsaw NC 283988820
❑ Denied Access
Wilmington
910-290-3077
Physical Address: 1769 Wards Bridge Rd Warsaw NC 28398
Facility Status: ❑ Compliant ❑ Not Compliant Integrator. Murphy -Brown LLC
Location of Farm: Latitude: 36' 00' longitude: 77° 59' 48"
North of Kenansville. On South side of SR 1300 approx. 0.3 miles East of SR 1301.
Question Areas:
Dischrge & Stream Impacts Waste Col. Stor. & Treat Waste Application
Records and Documents Other issues
Certified Operator. John C Byrd Operator Certification Number: 17181
Secondary OIC(s):
On -Site Represerrtative(s): Name Title Phone
24 hour contact name John Byrd Phone:
On -site representative John Byrd Phone
Primary Inspector. Kevin Rowland Phone:
Inspector Signature: Date:
Secondary Inspector(s):
Inspection Summary:
page: 1

Permit: AWS310305 Owner - Facility : Jahn C Byrd Fatality Number: 310305
Inspection Date: 06/19/14 Inpsection Type: Compliance Inspection Reason for Visit: Routine
Waste Structures Observed
oisignated
Type Identifier Closed Date Start Date Freeboard Freeboard
.agoon 2763 23.50
.agoon 2764 19.50
page: 2

Permit: AWS310305 Owner - Facility: John C Byrd Facility Number: 310305
Inspection Date: 06/19/14 Inpsection Type: Compliance Inspection Reason for Visit: Routine
Dlscharnes & Stream Impacts
Yes No Na No
1. Is any discharge observed from any part of the operation?
❑
0 ❑
❑
Discharge originated at:
Structure
❑
Application Field
❑
Other
❑
a. Was conveyance man-made?
❑
0 ❑
❑
b. Did discharge reach Waters of the State? (if yes, notify DWQ)
❑
0 ❑
❑
c. What is the estimated volume that reached waters of the State (gallons)?
d. Does discharge bypass the waste management system? (if yes, notify DWQ)
❑
M ❑
❑
2. Is there evidence of a past discharge from any part of the operation?
❑
0011
3. Were there any observable adverse impacts or potential adverse impacts to Waters of the
❑
0011
State other than from a discharge?
Waste Collection. Storane & Treatment
Yea No No No
4. Is storage capacity less than adequate?
❑
01111
If yes, is waste level into structural freeboard?
❑
5. Are there any immediate threats to the integrity of any of the structures observed (Le./ large
❑
01111
trees, severe erosion, seepage, etc.)?
6. Are there structures on -site that are not property addressed and/or managed through a
❑
0 ❑
❑
waste management or closure plan?
7. Do any of the structures need maintenance or improvement?
❑
M ❑
❑
8. Do any of the structures lack adequate markers as required by the permit? (Not applicable
❑
01111
to roofed pits, dry stacks and/or wet stacks)
9. Does any part of the waste management system other than the waste structures require
❑
01111
maintenance or improvement?
Waste ARRIlcation
Yea No No No
10. Are there any required buffers, setbacks, or compliance alternatives that need
❑ 0 ❑ ❑
maintenance or improvement?
11. Is there evidence of incorrect application?
❑ M ❑ ❑
If yes, check the appropriate box below.
Excessive Ponding?
❑
Hydraulic Overload?
❑
Frozen Ground?
❑
Heavy metals (Cu, Zn, etc)?
❑
PAN?
❑
Is PAN > 10%/10 lbs.?
❑
Total Phosphorus?
❑
Failure to incorporate manure/sludge into bare soil?
❑
Outside of acceptable crop window?
❑
Evidence of wind drift?
❑
Application outside of application area?
❑
page: 3

Permit: AWS310305 Owner - Facility : John C Byrd Facility Number: 310305
Inspection Date: 06/19/14 Inssection Type: Compliance Inspection Reason for Visit: Routine
Waste Application
Yes
No No Ne
Crop Type 1
Crop Type 2
Crop Type 3
Crop Type 4
Crop Type 5
Crop Type 6
Soil Type 1
Soil Type 2
Soil Type 3
Soil Type 4
Soil Type 5
Soil Type 6
14. Do the receiving crops differ from those designated in the Certified Animal Waste
❑
M ❑
❑
Management Plan(CAWMP)?
15. Does the receiving crop and/or land application site need improvement?
❑
0 ❑
❑
16. Did the facility fail to secure and/or operate per the irrigation design or wettable acre
❑
0 ❑
❑
determination?
17. Does the facility lack adequate acreage for land application?
❑
0 ❑
[]
18. Is there a lack of property operating waste application equipment?
❑
❑
❑
Records and Documents
Yas No Na No
19. Did the facility fail to have Certificate of Coverage and Permit readily available?
❑ M ❑ ❑
20. Does the facility fail to have all components of the CAWMP readily available?
❑0 ❑ ❑
If yes, check the appropriate box below.
WUP?
❑
Checklists?
❑
Design?
❑
Maps?
❑
Lease Agreements?
❑
Other?
❑
If Other, please specify
21. Does record keeping need improvement?
❑ ❑ ❑
If yes, check the appropriate box below.
Waste Application?
❑
Weekly Freeboard?
❑
Waste Analysis?
❑
Soil analysis?
❑
Waste Transfers?
❑
Weather code?
❑
Rainfall?
❑
Stocking?
❑
page: 4

Permit: AWS310305 Owner - Facility: John C Byrd Facility Number: 310305
Inspection Date: 06/19/14 Inpsection Type: Compliance Inspection Reason for Visit: Routine
Records and Documents
Yea
No No No
Crop yields?
❑
120 Minute inspections?
❑
Monthly and 1" Rainfall Inspections
❑
Sludge Survey
❑
22. Did the facility fail to install and maintain a rain gauge?
[]
0 ❑
❑
23. If selected, did the facility fail to install and maintain a rainbreaker on irrigation equipment
❑
N ❑
❑
(NPDES only)?
24. Did the facility fail to calibrate waste application equipment as required by the permit?
[]
NO
❑'
25. Is the facility out of compliance with permit conditions related to sludge? If yes, check the
❑
N ❑
❑
appropriate box(es) below:
Failure to complete annual sludge survey
❑
Failure to develop a POA for sludge levels
❑
Non -compliant sludge levels in any lagoon
❑
List structure(s) and date of first survey indicating non-compliance:
26. Did the facility fail to provide documentation of an actively certified operator in charge?
❑
N ❑
❑
27. Did the facility fail to secure a phosphorous loss assessment (PLAT) certification?
❑
E ❑
❑
Other Issues
Yes No Na No
28. Did the facility fail to properly dispose of dead animals within 24 hours and/or document
❑
N ❑
❑
and report mortality rates that exceed normal rates?
29. At the time of the inspection did the facility pose an odor or air quality concern? If yes,
❑
E ❑
❑
contact a regional Air Quality representative immediately.
30. Did the facility fail to notify regional DWQ of emergency situations as required by Permit?
❑
❑
❑
(i.e., discharge, freeboard problems, over -application)
31. Do subsurface file drains exist at the facility.
❑
N ❑
❑
If yes, check the appropriate box below.
Application Field
❑
Lagoon / Storage Pond
❑
Other
❑
If Other, please specify
32. Were any additional problems noted which cause non-compliance of the Permit or
❑
❑
❑
CAMP?
33. Did the Reviewerlinspector fail to discuss reviewrinspection with on4te representative?
❑
0 ❑
❑
34. Does the facility require a follow-up visit by same agency?
❑
0 ❑
❑
page: 5

A1,011W
r� s�Z",W.rr.r..m
NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins Dee Freeman
Governor Director Secretary
December 3, 2010
John C. Byrd
B & O Farm��
1229 Bowdens Rd
Warsaw, NC 28398
Subject: Sludge Survey Testing Dates
Certificate of Coverage No. AWS310305
B & O Farm
Animal' Waste Management System
�Iin County
Dear John C. Byrd:
- The.Division,of Water Quality (Division) received your sludge.survey information on November.
23, 2010. • With the survey results; .you requested an extension of the sludge survey requirement
for the front -lagoon (Lagoon. #.1) at the B & O Farm facility. Due to the amount of treatment
volume. available, -the Division agrees that'.a-sludge survey -is iiot needed -until 2014 for Lagoon;..
#1(front lagoon).
The-nextAsludge surveyfor the-front•lag'oon at B & O-Farm facility should be -performed before- -:-
December 31, 2014. Thank you for your attention to this matter. Please call me at (919) 715-
6937 if you have any questions.
Sincerely,
DEC 0 9 2010
BY;
w Miressa D. Garoma'
Animal Feeding Operations Unit
cc: Wilmington Regional Office, Aquifer Protection Section
Permit File AWS310305
1636 Mail Service Center. Raleivn, North Carolina 27699-1635
Location: 2720 Capltni S` vd.. Ra a qh. �lon Carolina 27604
?hone: 919.733-3221 1 F-.X: 919--15.0588': Customer Sevice: 1-877-623J37E8
Infomr-t: www ni- afnm:l�i€iiv.nm
an c[ t ?nnnoi,* n €., t F mrt,kn, Action F. r.".Y::Fr
One
NorthCarolina
a&raCl!
h

,AWS a to 34S
-Murphy-Brown, LLC 11/27/2006 2822 Hwy 24 West
P.O. Box 856
Warsaw, NC 28398
Grower(s):
Farm Name:
Countv:
NUTRIENT UTILIZATION PLAN
Oliver Outlaw/.John Byrd
B & O Farm
Duplin
Farm Capacity:
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder 5200
Feeder to Finish
Storage Structure:
Storage Period:
Application Method:
Anaerobic
>180 days
Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per.
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5- Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8
RECEIVED / DENR 1 DWQ
Aquifer Protection Section
MAR 10 2009

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft3, tons, etc.):
Capacity Type Waste Produced per Animal Total
Farrow to Wean
3212 gal/yr
gavyr
Farrow to Feeder
4015 gal/yr
gal/yr
Farrow to Finish
10585 gal/yr
gal/yr
5200
Wean to Feeder
223 gal/yr
1,159,600 gal/yr
Feeder to Finish
986 gallyr
gal/yr
Total 1,159,600 gallyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs):
Capacity Type Nitrogen Produced per Animal Total
Farrow to Wean
5.4 Ibs/yr
Ibs/yr
Farrow to Feeder
6.5 Ibslyr
ibs/yr
Farrow to Finish
26 lbs/yr
Ibs/yr
5200
Wean to Feeder
0.48 Ibslyr
2,496 Ibs/yr
Feeder to Finish
2.3 Ibslyr
lbs/yr
Total 2,496 Ibslyr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 45.48
Total N Required 1st Year: 7409.2
Total N Required 2nd Year: 5602.85
Average Annual Nitrogen Requirement of Crops: 6,506.03
Total Nitrogen Produced by Farm: 2,496.00
Nitrogen Balance for Crops: (4,010.03)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2of8

,Reception
Tract Field irrigated Soil Ist Crop Time to IstCrop 1stCrop LbsNLA-c -Lb­sN total -Fb—sN,.
Type Code Apply_I
51-T-KRZT-Wil
Mjj7y,.j
M.
_Acreage
3(a) of 8

Reception
Tract Field Irrigated Soil Ist Crop Timeto 1stCrop Ist Crop Lbs N/Ac Lbs N Total lbs Nj
Acrease Txe2 Cade Apply Yield lbs NIUnit Residual Ac Utilized
3fb) of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four.inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
IQtT*llrlil1l:9 11111:10=1k!l11
Crop Code
Crop
Lbs N utilized 1 unit yield
A
Barley
1.6 lbs N I bushel
B
Hybrid Bermudagrass - Grazed
50 lbs N 1 ton
C
Hybrid Bermudagrass - Hay
50 lbs N / ton
D
Com - Grain
1.25 lbs N / bushel
E
Com - Silage
12 lbs N 1 ton
F
Cotton
0.12 lbs N / lbs lint
G
Fescue- Grazed
50 lbs N [ton
H
Fescue - Hay
50 lbs N / ton
I
Oats
1.3 lbs N 1 bushel
J
Rye
2.4 lbs N 1 bushel
K
Small Grain - Grazed
50 lbs N 1 acre
L
Small Grain - Hay
50 lbs N I acre
M
Grain Sorghum
2.5 lbs N 1 cwt
N
Wheat
2.4 lbs N / bushel
O
Soybean
4.0 lbs N 1 bushel
P
Q
Pine Trees
\, IkAer X�I.kX \ ( �
40 lbs N 1 acre / yr
'1s Ra. (GLV-,
n
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4 of 8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PANT rlanimal Farm Totall r
Farrow to Wean 0.84
Farrow to Feeder 1
Farrow to Finish 4.1
5200 Wean to Feeder 0.072 374.4
Feeder to Finish 0.36
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 374.4 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 1872 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 6 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 14.976.acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to property
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid_
*This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may matte this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract Hydrant
Type
Crop
inlhr
* inches
MO A
GoA
D
0.4
1
B
GoA
D
0.4
1
C
WoA
D
o.4
1
D
WoA
D
o.4
1
E
WoA
D
0.4
1
F
WoA
D
0.4
1
G
AuB
D
0.6
1
H-1
AuB
G
0.6
1
H-2
AuB
G
0.6
1
1-1
AuB
G
0.6
1
1-2
AuB
G
0.6
1
J
AuB
D
0.6
1
K
AuB
D
0.6
1
6of8

Additional Comments:
This plan is written based on a two year crop rotation.
7 of 8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: B & O Farm
Owner: Oliver Outlaw/John Byrd
Manager:
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWO before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWO upon request.
Name of Facility Owner:
Signature:
Oliver Outlaw/John Byrd
Name of Manager (if different from owner)
Signature:
Date
Name of Technical Specialist: _
Amy E. Roberson _
Affiliation:
Murphy -Brown, LLC.
Address:
2822 Hwy 24 West, PO Drawer 856
Warsaw, NC 28398
Telephone:
[phone]
Signature: �. k` -ai -- d
Date
r-YOX3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recieving crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less.than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN -
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2of3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3of3

AOW�W a�>r
October 7, 2005
John Byrd
B&O Farms #2
1279 Bowden Rd.
Warsaw, NC 28398
RE: Sludge Survey Testing Dates
Facility # 31-'305!
Duplin County
Dear John Byrd:
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E. Director
Division of Water Quality
OCT 1_ 1 cuub
. r.
The Division of Water Quality (DWQ) received your request for a sludge survey
extension on September 29, 2005. Because the sludge was pumped from the lagoon in March,
DWQ agrees that a sludge survey is not needed until 2008.
Thank you for your attention to this matter
[phone].
cc: File# 31-305
Chester Cobb, Wilmington Regional Office
If you have any questions, please call me at
Sincerely,
Keith Larick
Ariimal Feeding Operations Unit
ow
Nr Carolina
,mural!
Aquifer Protection Section 1636 Mail Service Center Raleigh, NC 27699-1636
Internet: http:/Wo.enr.state.nc.us 2728 Capital Boulevard Raleigh, NC 27604
An Equal OpportunitylAtfnmalive Action Employer— 50% RerycIedl50% Post consumer Paper
Phone [phone] Customer Service
Fax [phone].623-6748
Fax [phone]

Waste Structure Cleanout Plan ,
RRICEIVED
1r 2005
This plan has been prepared for:
Oliver Outlaw Farm31305
Oliver Outlaw
1769 Wards Bridge Rd
Warsaw, NC 28398
910-293-7370
06-1 0-2005 1 %J u �
fThis plan has been developd!
Billy W Houston
Duplin Soil & Water Conservation
PO Box 219
Kenansville, NC 28349
910-296- 2120
e./�V /g""e
Devellra Signature
Type of Plan: Waste Structure CleanOut Plan
O-,vner/Manager/Producer Agreement
I (we) understand and agree to the specifications and the operation and maintenance procedures
established in this Cleanout plan.
Signature (owner)
G
Signature (manager or producer)
6 -/Y -boa- -
Date
Date
This plan meets the minimum standards and specifications of the U.S. Department of Agriculture -
Natural Resources Conservation Service or the standard of practices adopted by the Soil and Water
Conservation Commission.
Plan Approved By: / '�✓ ,sir
Technical Specialist Signature
(, I //6/of-
Date
,------------------------ ---------------------------------------------------------- ---------------
----------------------------- ----
----------------- -
286846 Database Version 3.1 Date Printed: 06-10-2005 Cover Page 1

61
5
Waste Storage Cleanout Source Description
SOURCE: Sludge #2
Date Measured: 04-18-2005
Lagoon Dimensions: TOP - 153 X 156; BOTTOM - 93 X 96, SIDE SLOPES - 3:1
Sludge Depth: 3.50ft.; Sludge Volume: 289,535 gallons. Waste Sample #: W09118
Estimated Pounds of Plant Available Nitrogen
Broadcast
1513
Incorporated
1802
Injected
1931
Irrigated
1416
Maximum PAN
Available (lbs.) *
Actual PAN Applied
(lbs)
PAN Surplus/
Deficit (lbs)
Actual Volume
Applied (Gallons)
Volume Surplus/
Deficit (Gallons)
1,416
3,546
-2,130
1,226,783
-937,248
----•------------------------ ---------------------------------------------------------------------
* Maximum PAN AvaifabEe is calculated on the basis of the actual application method(s) identified in the plan for this source.
Database Version 3.1 Date Printed: 06-10-2005 Desc. 1

The table shown below provides a summary of the crops or rotations included in this plan for each field. Realistic Yield estimates are also
provided for each crop, as well as the crop's P205 Removal Rate. The Leaching Index (LI) and the Phosphorous Loss Assessment Tool
(PLAT) Rating are also provided for each field, where available.
If a field's PLAT Rating is High, any planned manure application is limited to the phosphorous removal rate of the harvested plant biomass
for the crop rotation or multiple years in the crop sequence. Fields with a Very High PLAT Rating should receive no additional
applications of manure. Regardless of the PLAT rating, starter fertilizers may be recommended in accordance with North Carolina State
University guidelines or recommendations. The quantity of P205 applied to each crop is shown in the following table if the field's PLAT
rating is High or Very High.
Planned Crops Summary
Tract
Field
Total
Acres
Useable
Acres
Plat
Ratio g
LI
Soil Series
Crop Sequence
RYE
P205
Remora]
(lbs/acre)
Applied
(Ibs/acre)
3120
1
14.13
12.00
Unknown
NIA
Autryville
Rye, Grain
45 bu.
15
NIA
3120
1 2
15.071
13.001
Unknown
NIA
Autryville
Rye, Grain
45 bu.
15
NIA
PLAN TOTALS: 29.20 25.00
Low potential to contribute to soluble None
< 2 nutrient leaching below the root zone.
]= 2 & Moderate potential to contribute to soluble Nutrient Management (590) should be planned.
<= 10
nutrient leaching below the root zone.
High potential to contribute to soluble Nutrient Management (590) should be planned. Other conservation practices that improve the soils
nutrient leaching below the root zone. available water holding capacity and improve nutrient use efficiency should be considered. Examples
> 10 are Cover Crops (340) to scavenge. nutrients, Sod -Based Rotations (329), Long -Term No -Till (778),
and edge -of -field practices such as'Filter Strips (393) and Riparian Forest Buffers (391).
0 - 25 Low No adjustment needed; N based application
25 - 50 Medium No adjustment needed; N based application
51 - 100 High Application limited to crop P removal
> 100 Very High Starter P application only
286846 Database Version 3.1
Date Printed 6/ 10/2005
PCs Page Page 1 of 1
NOTE; Symbol * means user entered data.

Land Application Table: Sludge #2
Source Type: Cleanout
Manure
PAN
AApplied
Liquid
Req'd
Manure
Crop
A
(Ibs/A)
(lbs/A)
Applied
Applic.
Source
Total
Use.
PLAT
Applic,
1000
Amount
(Inches)
Applic.
Tract
Field
ID
Soil Series
Acres
Acres
Rating
Crop
RYE
Period
Method
N
N
gal/Acre
3120
1
U2
Autryvillc
14.13
12.00
NIA
Rye, Grain
45 bu.
9/1-3/31
Irrig.
104
104
21.26
6.78
3120
2
U2
Autryville
15.07
13.00
N/A
Rye, Grain
45 bu.
9/1-3/31
1 Irrig.
104
104
21.26
0.78
NOTE: * indicates user defined value
Sludee #2 Summary:
Source Volume Available
Source Volume Applied:
Excess Application Capacity
289,535 gals.
531,606 gals.
83.6
286846 Database Version 3.1
Date Printed: 6/10/2005
LAT Page Page I of 1
11

Lagoon sludge often contains high concentrations of zinc and copper. High levels of these metals in soils can adversely affect plant growth. The following table provides a
conservative (maximum potential) estimate for increase in soil index values.* Due to inherit variability of waste and soil sampling, it is recommended that conservative soil
target levels beset for copper (e.g. Cu-I < 700-1000) and zinc (e.g. Zn-1 < 300 for land where peanuts maybe grown; for other cropland Zn-1 < 700-1000). Alternative
application sites should be selected if the following table indicates that concentrations of these metals may approach excessive levels. For maximum copper and zinc soil index
limits, see the NRCS Nutrient Management Standard (Code 590).
Estimated Soil Metal Concentrations
Tract
field
Soil Sample
Crop
Source:
11)
Applic.
haches
Waste;
Cuppm
Waste
Znppm
Soil'rest
CA
Soil Test
Za-I
Cu-I
Adj.
"Z11-1
Adj.
listimated New
dumber
Date
Soil Cu-I
Soil Zn-I
3120
1
075775
10-19-04
Rye, Grain
U2
0.78
128
500
88
651
629
1,245
717
1,896
3120
2
075776
10-19-04
Rye, Grain
U2
0.78
128
500
F 1 42
558
629
1,245
671
1,803
* NOTE: Ilie equilibrated post application soil index may be less than the projected ntilximum value. Practical methodology tier more precise estimation is not available.
296846 Database Version 3.1 Date Printed: 06-10-2005 Metals Page Page I of 1

GENERAL LAGOON CLEANOUT INFORMATION:
Cleanout Start Date: 10-10-2005 Cleanout End Date: 11-10-2005
Sludge Volume Is AN Estimate Taken Given 2.8 ft Of Existing Suldge And 0.7ft Of Water, On
Top Of Sludge, For Agitation And Spredding Of Effluent(Sludge).
------------------------------------------------ -------------------------------------------------------------------------------------------------------------------
286846 Date Printed: 06-10-2005 Info Page 1

Crop Notes
The following crop note applies to field(s): 1, 2
Rye, Grain: CP, Mineral Soil, medium leachable
[n the Coastal Plain, oats and barley should be planted from October 15-October 30; and rye from October
15-November 20. For barley, plant 22 seed/drill row foot and increase the seeding rate by 5% for each
week seeding is delayed beyond the optimum time. See the seeding rates table for applicable seeding rate
modifications in the current NCSU "Small Grain Production Guide". Also, increase the initial seeding rate
by at least 10% when planting no -till. Oats should be planted at 2 bushels/acre and rye at 1-1 1/2
bushels/acre. Plant all these small grains at 1-1 1/2" deep. Adequate depth control is essential. Review the
NCSU Official Variety "green book" and information from private companies to select a high yielding
variety with the characteristics needed for your area and conditions. Apply no more than 30 lbs/acre N at
planting. Phosphorus and potash recommended by a soil test can also be applied at this time. The
remaining N should be applied during the months of February -March. The total N is dependent on the soil
type. Plant samples can be analyzed during the growing season to monitor the nutrient status of the oats,
barley and rye. Timely management of diseases, insects and weeds are essential for profitable oat, barley
and,rye production.
-----------------------------------------------------------------------------------------------------------------------------------------------------
286846 Database Version 3.1 Date Printed: 06-10-2005 Crop Note Page Page 1 of 1

Phone: [phone],,- " Web Site: wwwxcagrxotWagronomi/ % Report: W09 118
Grolver:
Byrd, ohn ColVes 7b:
1769 W Wards Bridge Rd
W
JID I aste Analysis Report
Warsaw, NC 28398
Farm:
5/27/2005
Duplin County
P-Oft1*102flab r'..
Laboratory Results (parts per million unless otherwise noted)
Sample ID.
N
P K Ca At S
PC AN 7n Cu 11 MO (11 C
7blal 1332
IN-N
1089 716 1360 526 669
507 31.4 500 128 0.59
Waste Code.,
-NI14
ASS
-NO3
Na Ni ("d A it/
SO Ii P 11 SS C.-N DA11% (XI'llyu AII(Xga))
Deseription.
OR-N
115
7.32
Swine Lsoon Sludge
Urea
Raomimidations:
Nutrients Available for First Crop
lbs11000 gallons
Other Elements lbs11000,gallonk
Application Method
N P205 K20 Ca Mg S Fe Mn Z11 Cu
B MO Cl
Na Ni Cd A Al Se Y
Inipflon
5.1 14.6 5.7 7.9 .3.1 3.9 3.0 0.18 2,9 OA
T
0.96
Broadcast
5.1 14.6 5.7 7.9 3.1 3.9 3.0 0.18, 2.9 ' 0.74
T
0,96
The waste, product contains large amounts of phosphorus, zinc, and copper. The waste should be applied at rates needed to meet crop nitrogen requirement unless one of the ollier elements are more restrictive. When
son test P,ls,;kq high and the site is vulnerable to phosphorus movement to nearby surface miter, limit application of P to estimated crop removal of this element. Limit zinc and copper application as necessary to avoid
excess accumulation of these elements in the soil.

Rai.nman Environmental, LLC
Post Office Box 115
Kenansvi[!e, NC 28349
Lagoon Sludge Survey Form
Farm Permit or DWQ Identification Number B&O Farms
Lagoon Identification #1 Nursery (first you get too)
Person(s) Taking Measurements Donavan Brock
Date of Measurements 18-Apr-05
Methods/Devices Used for Measurement of:
a. Distance from the lagoon liquid surface to the top of the sludge layer: Disk
b. Distance from the lagoon liquid surface to the bottom (soil) of the lagoon: Grade Rod
c. Thickness of the sludge layer if making a direct measurement with "core sampler': NA
Lagoon Surface Area (using dimensions at inside top of bank): 0.5 acres
Estimate number of sampling points:
a. Less than 1.33 acres: Use 8 points
b. If more than 1.33 acres: 0.5 x with maximum of 24.
At the time of the sludge survey, also measure the distance from the Maximum Liquid Level
to the Present Liquid Level (measure at the lagoon guage pole): 19 Inches
Determine the distance from the Maximum Liquid Level to the Minimum Liquid Level 24 Inches
The distance from the present liquid surface level to the Minimum Liquid Level 0.42 Feet
Record from the Sludge Survey Data Sheet the distance from the present liquid surface level
to the lagoon bottom (average for all the measurement points): 9.1fi Feet
Record from the Sludge Survey Data Sheet the distance form the present liquid surface level
to the top of the sludge layer (average for all the measurement points): 7.1 Feet

Record from the Sludge Survey Data Sheet the average thickness of the sludge layer. 2.0 Feet
Calculate the thickness of the existing Liquid Treatment Zone: 6.7 Feet
Note: If the Calculated thickness of the existing Liquid Treatment Zone is less than 4 feet, a
sludge removal and utilization plan may be required by N. C. DWQ. See your specific permit or
contact DWQ for more information.
Completed By: Danna Westerbeek
Printed Name
Signature
I J Date

Rainman Environmental, LLC
Post Office Box 115
Kenansville, NC 28349
Appendix 2: Sludge Survey Data Sheet
Farm Permit or DWQ Identification Number
Lagoon Identification
Person(s) Taking Measurements
Date of Measurements
B&O Farms
91 Nursery (first you get too)
Donavan Brock
18-Apr-05
Grid Point Distance from liquid Distance from liquid Thickness of sludge
Number surface to top of surface to lagoon layer
sludge bottom (soil) y
1
2.50
7.8
5.30
2
7.50
8.7
1.20
3
7.40
7.9
0.50
4
9.00
10.1
1.10
5
8.90
10
1.10
6
7.00
9.8
2.80
7
5.70
8.5
2.80
8
7.70
10
2.30
9
8.50
9.6
1.10
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
Average
7.1
9.2
2.0

Rainman Environmental, LLC
Post Office Box 115
Kenansville, NC 28349
Appendix 2: Sludge Survey Data Sheet
Farm Permit or DWQ Identification Number
Lagoon Identification
Person(s) Taking Measurements
Date of Measurements
B&O Farms
#1 Nurser(first you get too)
Donavan Brock
18-Apr-05
Average Sludge Layer Thickness
2.0
Depth of lagoon from top of bank to bottom soil surface
12.4
Slope = horizontal/vertical side slope
3
Length at top inside bank
141
Width at top inside bank
156
Length at midpoint of sludge layer
72.7
Width at midpoint of sludge layer
87.7
Volume of sludge
12,882
Volume in gallons
96,618

Field Form for Sludge Survey (complete one per lagoon surveyed)
Enstance rn
Liquid Surface to
Thickness of
Grid Point
Water Depth
Toe of Sludge
Sludge
Additional Information
1
'p.
2
'
�7, 5—
Farm Name:
3
'2,
Date:
e
�`?
Grower:
9
t•
10
11
Lagoon ID:
12
13
14
Top of Dike Elevation:
feet
15
16
17
Bottom of Dike Elevation:
feet
18
19
20
s =
Start Pump Level:
feet
21
22
s
23
Stop Pump Level:
feet
24
` Lagoon Sketch
and Mapping
Current Freeboard:
inches
-
- -- - - -
Top of Dike Length:
feet
Top of Dike Width:
I
\D
�,
feet
Signature of Person
Completing Survey:
"Note: All grid point
~---
lq
measurements are in feet

Ramman Environmental, LLC
Post Office Box 115
Kenansville, NC 28349
Lagoon Sludge Survey Form
Farm Permit or DWO Identification Number B&O Farms
Lagoon Identification #2 Nursery (back)
Person(s) Taking Measurements Donavan Brock
Date of Measurements 18-Apr-05
Methods/Devices Used for Measurement of:
a. Distance from the lagoon liquid surface to the top of the sludge layer: Disk
b. Distance from the lagoon liquid surface to the bottom (soil) of the lagoon: Grade Rod
c. Thickness of the sludge layer if making a direct measurement with "core sampler": NA
Lagoon Surface Area (using dimensions at inside top of bank): 0.5 acres
Estimate number of sampling points:
a. Less than 1.33 acres: Use B points
b. If more than 1.33 acres: 0.5 x with maximum of 24.
At the time of the sludge survey, also measure the distance from the Maximum Liquid Level
to the Present Liquid Level (measure at the lagoon guage pole): 15 Inches
Determine the distance from the Maximum Liquid Level to the Minimum Liquid Level 24 Inches
The distance from'the present liquid surface level to the Minimum Liquid Level 1 0.75 Feet
Record from the Sludge Survey Data Sheet the distance from the present liquid surface level
to the lagoon bottom (average for all the measurement points): 7.07 Feet
Record from the Sludge Survey Data Sheet the distance form the present liquid surface level
to the top of the sludge layer (average for all the measurement points): 4.3 Feet

Record from the Sludge Survey Data Sheet the average thickness of the sludge layer: 2.8 Feet
Calculate the thickness of the existing Liquid Treatment Zone: I 3.5 Feet
Note: If the Calculated thickness of the existing Liquid Treatment Zone is less than 4 feet, a
sludge removal and utilization plan may be required by N. C. DWQ. See your specific permit or
contact DWQ for more information.
Completed By: Danna Westerbeek
Printed Name
Signature
" I ` ( s -OS Date

Rainman Environmental, LLC
Post Office Box 115
Kenansville, NC 28349
Appendix 2: Sludge Survey Data Sheet
Farm Permit or DWQ Identification Number
Lagoon Identification
Person(s) Taking Measurements
Date of Measurements
B&O Farms
#2 Nursery (back)
Donavan Brock
18-Apr-05
Grid Point Distance from liquid Distance from liquid Thickness of sludge
Number' surface to top of surface to lagoon layer
sludge bottom (soil) Y
1
3.90
7
3.10
2
3.60
6.9
3.30
3
4.00
7.2
3.20
4
5.30
7.2
1.90
5
4.20
7.1
2.90
6
4.20
7
2.80
7
4.10
7
2.90
8
4.50
7.2
2.70
9
4.50
7
2.50
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
Average
4.3
7.1
2.8

Rainman Environmental, LLC
Post Office Box 115
Kenansville, NC 28349
Appendix 2: Sludge Survey Data Sheet
Farm Permit or DWQ Identification Number
Lagoon Identification
Person(s) Taking Measurements
Date of Measurements
B&O Farms
#2 Nursery (back)
Donavan Brock
Average Sludge Layer Thickness
Depth of lagoon from top of bank to bottom soil surface
Slope = horizontal/vertical side slope
Length at top inside bank
Width at top inside bank
Length at midpoint of sludge layer
Width at midpoint of sludge layer
Volume of sludge
Volume in gallons
18-Apr-05
2.8
10
3
153
156
101.4
104A
29,778
223,336

rdialu F-%84121 1%A '04amqje ourvey keompiete one per lagoon surveyed)
Lkstaime from
LkpM Surface to
Thickness of
Grid Point
Water Depth
Top of Sludge
Sludge
Additional Information
Farm Name:
2
- -- p_,
3
4
5
2,/
Date:
&
7
8
y,
Grower:
6k 9
10
11
Lagoon ID:
12
13
14
Top of Dike Elevation:
feet
15
16
17
Bottom of Dike Elevation:
feet
18
19
20
Start Pump Level-
feet
21
22
231
Stop Pump Level:
feet
241
Lagoon Sketch
and Mapping
Current Freeboard:
inches
Top of Dike Length:
feet
Top of Dike Width:
feet
Signature of Person
Completing Survey:
*Note: All grid point
measurements are in feet

o f WA rF9 Michael F. Easley, Governor
0 p William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
j Alan W. Klimek, P. E., Director
'f Division of Water Quality
f' "C
Oliver Outlaw
B&O Farm -
1769 Wards Bridge Rd
Warsaw NC 28398
May 1, 2003
Subject: Certificate of Coverage No. AWS310305
B&O Farm
Swine Waste Collection, Treatment,
Storage and Application System
Duplin County
Dear Oliver Outlaw:
On April. 28, 2003, the North Carolina General Assembly ratified Senate Bill 733 which directs the
Division of Water Quality (Division) to extend the expiration date of the Swine Waste Operation General
Permit AWG100000. Therefore, the General Permit has been re -issued by the Division to extend the
expiration date to October 1, 2004. During the period of this extension the Division will be working with
all interested parties on the development of a new version of the Non -Discharge General Permit.
In accordance with your application received on January 16, 2003 and in accordance with the directive of
Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to Oliver
Outlaw, authorizing the operation of the subject animal waste collection, treatment, storage and land
application system in accordance with General Permit AWG100000. The issuance - of this COC
supercedes and terminates your previous COC Number AWS310305 which expired on April 30, 2003.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the B&O Farm, located in Duplin County, with an animal capacity of no greater
than an annual average of 5200 Wean to Feeder swine and the application to land as specified in the
facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or Farrow to
Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary, they may
be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a rate of 4
gilts for every 3 sows
The COC shall be effective from the date of issuance until October 1, 2004. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Pei=inittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property. :WA
W®R
Non -Discharge Permitting Unit Internet http:Yh2o.enr.state.nc.us/ndpu
1617 Mail Service Center, Raleigh, NC 27699-1617 Telephone [phone] Fax [phone]
Customer Service Center Telephone [phone]
An Equal Opportunity Action Employer 50% recycled/10% post -consumer paper

Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per NRCS standards a - 100 foot separation shall be maintained between water supply wells and any
lagoon or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name./ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Wilmington Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Sue Homewood at [phone] ext. 502.
Sincerely,
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG 100000)
cc: (Certificate of Coverage only for all cc's)
Wilmington Regional Office, Water Quality Section
Duplin County Health Department
Duplin County Soil and Water Conservation District
Permit File AWS310305
NDPU Files

ANIMAL WASTE UTILIZATION PLAN
Producer: OLIVER OUTLAW/JOHN BYRD
Location: 1769 WARDS BRIDGE RD
WARSAW NC 28398
Telephone:- 910-293--7370
Type Operation: Existing Wean to Feeder Swine
Number of Animals: 5200.00 pigs
(Design Capacity)
STORAGE STRUCTURE: Anaerobic Waste Treatment Lagoon
APPLICATION METHOD: Irrigation
A
The waste -from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops
in the fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply
more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall be applied to land eroding at less than
5 tons per acre per year.' Waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on -saturated soils, when it is raining,
or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed
under DWQ regulations.
Page: 1

ANIMAL WASTE UTILIZATION PLAN
5. Wind conditions should also be considered to avoid drift and
downwind odor problems.
6. To maximize the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more than 30
days prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. If
you choose to change methods in the future, you need to revise this
plan. Nutrient levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from your
waste management facility. In some cases you may want to have plant
analysis made, which could allow additional waste to be applied.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
This waste utilization plan, if carried out, meets the requirements
for compliance with 15A"NCAC 2H .0217 adopted by the Environmental
Management'Commission. .
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, £t3, tons, etc.)
5200 pigs x .40 tons waste/pigs/year = 2080 tons
AMOUNT. OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
5200 pigs x .96 lbs PAN/pigs/year = 4992 lbs. PAN/year
Applying the above amount of waste is a big job. You should plan
time and have -appropriate equipment to apply the waste in a timely
manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
Page: 2

ANIMAL WASTE UTILIZATION PLAN
TABLE 1: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
------
APPLY
RESID.
APPLIC
METH
N
TIME
3120
8
AUB
C
75
73.75
20
16.9
1246.37
I
MAR-JUN
3120
1-8
f
IWIA
11
1100 I-
116.9
SEPOAPR
3120
DSB
.8
1-8
JAUB
I
118
172 1
116.9
11216
JUN-
SEPT 15
3120
9
FP
3.0
IFOA
I
I
1150 1
19.9
11485
SEP-APR
3120
FP
3.0
1-9
IFOA
I
1
1150 1
19.9
11485
SEP.-APR
3120
10
AUB
IC
I
175
173.75 120
132.4
12389.5
MAR--JUN
3120
--10
1
IWA
I
1100 1
132.4
13240
SEP-APR
3120
--10
DSB
JAUB
li
118
172. 1
132.4
12332.8
JUN-
SEPT 15
3120
13.0
1-10A
IGOA
IC
I
1125
1136.25120
11771.25
MAR-JUN
3120
10A
1
IWA
I.
1100 1
113
11-300
SEP-APR
3120
�10A
DSB
IGOA
I
135
1140
113
11820
JUN-
SEPT 15
3120
--10A
TO
0
0
IGOA
I
1
1
113-0
END
Page: 3

ANIMAL WASTE UTILIZATION PLAN
TOTALII9976.7
V - Indicates that this field is being overseeded (i.e.
interplanted) or winter annuals follow summer annuals.
NOTE: The applicator is cautioned that P and K may be over applied
while meeting the N requirements. In the future, regulations
may require farmers in some parts of North Carolina to have a
nutrient management plan that addresses all nutrients. This
plan only addresses nitrogen.
Page: 4

ANIMAL WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
See required specification 2.)
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
-------
APPLY
RESID.
APPLIC
METH
N
TIME
END
TOTAL10
Indicates that this field is being overseeded (i.e. interplanted) or
winter annuals follow summer annuals.
** Acreage figures may exceed total acreage.in fields due to
overseeding.
* 1bs-AW--N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables I and 2 above:
CROP CODE
CROP
UNITS
PER UNIT
C
CORN
BUSHELS
1.25
DSB
DOUBLE CROPPED SOYBEANS
BUSHELS
4
FP
TALL FESCUE -PASTURE
TONS
50
TO
TOBACCO
WA
WINTER ANNUALS (I.E. Small Grains, etc.)
AC
100
TOTALS FROM TABLES 1 AND 2
Page: 5

ANIMAL WASTE tTTILIZATION PLAN
TABLE 1
TABLE 2
WETTABLE
ACRES
59.2
0
LBS AW N USED
19976.72
0
TOTAL [ 59.2 19976.72
*** BALANCE1 --14984.725
-------------------
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.
Page: 6

ANIMAL WASTE UTILIZATION PLAN r
*** This number must be less than or equal to 0 in order to fully
utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffers, filter strips along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than
the acres shown in the tables.
See attached map showing the fields to be used for the utilization of
animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient
rich and will require precautionary measures to prevent over application
of nutrients or other elements. Your production facility will produce
approximately 395.2 pounds of plant available nitrogen per year in the
sludge.
If you remove the sludge every 5 years, you will have approximately 1976
pounds of PAN to utilize. Assuming you apply this PAN to hybrid
bermudagrass hayland at the rate of 300 pounds of nitrogen per acre, you
will need 6.58666666667 acres of land. If you apply the sludge to corn at
the rate of 125 pounds of nitrogen per acre, you will need 15.808 acres
of land. Please be aware that these are only estimates of the PAN and
land needed. Actual requirements could vary by 25o depending on your
sludge waste analysis, soil types, realistic yields, and application
methods
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the
soil at the time of irrigation such that runoff or ponding occurs. This
rate is limited by initial soil moisture content, soil structure, soil
texture, water droplet size, and organic solids. The application amount
should not exceed the available water holding capacity of the soil at the
time of irrigation nor should the plant available nitrogen applied exceed
the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables 1 and 2. Failure to apply the recommended rates and
Page: 7

r.
ANIMAL WASTE UTILIZATION PLAN
amounts of nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application
rates and amounts.
Tract
I I
[ Field [
I I
Soil Type
I
[ Crop
I
3120
110 I
AUB
I C
3120 [
8 [
AUB
[ C
I
3120 [
I
9 I
FOA
[ FP
I
3120 [
I
- 10 [
I
[ WA
3120 I
I
--10 I
AUB
I DSB
1
I
3120 [
-10A [
I WA
3120 I
--10A I
GOA
[ DSB
3120 I
I
--10A I
GOA
I
[ TO
3120 I
I
--10A I
GOA
I
[ C
3120 I
-8 I
I WA
[Application Rate[Applic. Amount
(in/hr)
I
[
(inches)
.5
I *1
I
•5
[ *1
1
[ .50
[ *1.0
I
.35
[ *1
1
I -5
I *1
[ .35
[ *1
I
[ .50
I
[ *1.0
I
I
I *
I
[ .50
I *1.0
I
[ .35
[ *1
Page: 8

1 ANIMAL WASTE UTILIZATION PLAN
f
3120
I
I -8
I
I AUB
I
DSB I
3120
I
--9
I
I FOA
!
I I
+ FP
I I
.5
*1
.50 [ *1.0
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations, the application amount shown cannot
be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180.00 days of temporary storage and
the temporary storage must be removed on the average of once every
6.00 months. In no instance should the volume of the waste be stored
in your structure be within the 25 year 24 hour storm storage or one
foot of freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply the
correct rates to the acres shown in Tables I and 2. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may.
make this plan invalid.
Call your technical specialist after you receive the waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate prior to_applying the waste.
NARRATIVE OF OPERATION
THIS PLAN IS WRITTEN BASED ON A TWO YEAR CROP ROTATION. FIELD NUMBER 10A WILL
HAVE A TWO YEAR ROTATION THAT INCLUDES TOBACCO. THERE WILL BE NO PUMPING WHEN
TOBACCO IS PLANTED ON THIS FIELD. THERE WILL BE EITHER CORN OR SOYBEANS
PLANTED DURING THE OTHER CROP YEAR. TABLE ONE ON PAGE THREE GIVES THE NUTRIENT
BUDGET TO BE USED FOR PUMPING ON EACH FIELD. THE WINTER ANNUAL(WA) IS A SMALL
GRAIN CROP TO BE PLANTED BEHIND CORN. THIS CROP MAY BE EITHER GRAZED OR
HARVESTED.
Page: 9

(` WASTE UTILIZATION '°,PLAN .
REQUIRED SPECIFICATIONS
1. Animal waste•shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
S. Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
6, When -animal waste is -to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
-grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be considered.
Page: 10

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to
wells.
13. Animal waste shall not be applied closer than 200'feet of
dwellings other than those owned by the landowner.
14. waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly into water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
-the' site.
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system:
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 11

ll UTILIZATION
WASTE UT ION PLAN -
REQUIRED SPECIFICATIONS
18. If animal production at the facility is to be suspended or
terminated, the owner'is responsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22. Waste shall be tested within 60 days of utilization and soil
shall be'tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when these
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be
maintained for five ( S ) years.
23:-Dead-animals will be disposed of in a manner that meets North
Carolina regulations.
Page: 12

ANIMAL WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: B&O #102
Owner/Manager Agreement
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
North Carolina Division of Water Quality (NCDWQ) before the new
animals are stocked. I (we) also understand that there must be no
discharge of animal waste from this system to surface waters of the
state from a storm event less severe than the 25-year, 24-hour
storm. The approved plan will be filed on -site at the farm office
and at the office of the local Soil and Water Conservation District
and will be available for review by NCDWQ upon request.
Name of Facility Owner: OLIVER OUTLAW/JOHN BYRD
(Please print)
Signature: `t Date:
Name of Manager (If different from owner)
Signature: Date:
Name of Person Preparing Plan: (please print)BILLY W. HOUSTON
Affiliatian:DUPLIN SOIL AND WATER CONSERVATION DISTRICT
Phone No. 910-296-2120
Address (Agency): PO BOX 277
KENANSVILLE NC 28349
Signature: �AS") w _ Date: -S-
Page: 13

North Carolina
Department of Environment and Natural Resources
Water Pollution Control System Operator Certification Commission f
Michael F. Easley, Governor William G. Ross Jr., Secretary D E ■ R �
Coleen H. Sullins, Chairman
July 26, 2001
Oliver Outlaw
1769 Wards Bridge Rd
Warsaw NC 28398
SUBJECT: Designation of Operator in Charge
Farm Name: B&O Farm
Facility ID #. 31-305 ,
County: Duplin
Dear Mr. Outlaw.
Senate Bill 1217, enacted by the North Carolina General Assembly on June 21, 1996, requires that a certified operator
be designated as the Operator in Charge (OIC) for each animal waste management system that serves 250 or more
swine, 100 or more confined cattle, 75 or more horses, 1,000 or more sheep, or 30,000 or more confined poultry with a
liquid animal waste management system. Senate Bill 1217 further requires that each certified animal waste
management system operator obtain six hours of approved continuing education training during each three-year period
following initial certification. An operator who fails to complete the required training within 30 days of the end of the
three-year period must take and pass the examination for certification in order to become recertified.
According to Division records, John Byrd is the designated Operator in Charge for your animal waste management
system. However, Mr. Byrd is no longer a certified animal waste management system operator because he did not
complete the six hours of required continuing education training by December 31, 2000. Therefore, you must
designate a properly certified animal waste management system operator as the Operator in Charge for your facility.
The enclosed designation form must be returned to this office within 30 days of receipt of this letter. This office
maintains a list of certified operators in your area if you need assistance in locating a certified operator. Failure to
designate a properly certified Operator in Charge for your facility is a violation of N.C.G.S. 90A-47.2 and
15A NCAC 8F .0201(a) and may result in the initiation of enforcement action.
1618 Mail Service Center, Raleigh, North Carolina 27699-1618
Phone: 919 - 733-0026 1 FAX: 919 - 733-1338
AN EQUAL OPPORTUNITY 1 AFFIRMATIVE ACTION EMPLOYER - 50% RECYCLED / 10% POST CONSUMER PAPER

Oliver Outlaw
Page Two
July 25, 2001
If you have questions concerning this matter, or if this office can be of further assistance, please call Beth Buffington at
[phone], extension 313.
Sincerely,
Tony Arnold, Acting Supervisor
Technical Assistance and Certification Unit
Enclosure
cc: TAC Files
Non -Discharge Compliance/Enforcement Unit
Wilmington Regional Office]
Central Files
John Byrd

6' ,State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Oliver Outlaw
B&O Farm
1769 Wards Bridge Rd
Warsaw NC 28398
Farm Number: 31 - 305
Dear Oliver Outlaw:
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
RECEIVED
March 15, 2000 WATER QuALffy sEc*nON
Wn-Dscharge PermlWflg
You are hereby notified that B&O Farm, in accordance with G.S. 143-215.10C, must apply for coverage under an
Animal Waste Operation General Permit. Upon receipt of this letter, your farm has sixty (60) days to submit the attached
application and all supporting documentation. In accordance with Chapter 626 of 1995 Session Laws (Regular Session
1996), Section 19(c)(2), any owner or operator who fails to submit an application by the date specified by the
Department SHALL NOT OPERATE the animal waste system after the specified date. Your application must be
returned within sixty (60) days of receipt of this letter. Failure to submit the application as required may also subject your
facility to a civil penalty and other enforcement actions for each day the facility is operated following the due date of the
application.
The attached application has been partially completed using information listed in your Animal Waste Management
Plan Certification Form. if any of the general or operation information listed is incorrect please make corrections as noted on
the application before returning the application package. The signed original application, one copy of the signed application,
two copies of a general location map, and two copies of the Certified Animal Waste Management Plan must be returned to
complete the application package. The completed package should be sent to the following address:
North Carolina Division of Water Quality
Water Quality Section
Non -Discharge Permitting Unit
1617]'.'Iail Service Center
Raleigh, NC 27699-1617
If you have any questions concerning this letter, please call 7 R 7oshi at [phone] extension 363 or Dean
Hunkele with the Wilmington Regional Office at [phone]. �.
Sincer
for Kerr T, Stevens
cc: Permit File (w/o encl.)
Wilmington Regional Office (w/o encl.)
1617 Mail Service Center, Raleigh, NC 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

State of North Carolina
Department of Environment and Natural Resources WATEREl D
Division of Water Quality nON
Non -Discharge Permit Application Form hfAR 2 Q 2000
(THIS FORM MA Y BE PHOTOCOPIED FOR USE AS AN ORIGINAL)
General Permit - Existing Animal Waste Operations Nor -Discharge PaMtUn$
The following questions have been completed utilizing information on file with the Division. PIease
review the information for completeness and make any corrections that are appropriate. If a
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
1. GENERAL INFORMATION:
1.1 Facility Name: B&O Farm
1.2 Print Land Owner's name: Oliver Outlaw
13 Mailing address: 1769 Wards Bridge Rd
City, State: Warsaw NC Zip:
Telephone Number (include area code): 293-7370
1.4 County where facility is located:
1.5 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a copy
of a county road map with the location of the farm identified): On south side of SR 1300 approx. 0.3 miles east of
intersection with SR 1301.
1.6 Print Farm Manager's name (if different from Land Owner):
1.7 Lessee's / Integrator's name (if applicable; please circle which type is listed): Murphy Family Farms
1.8 Date Facility Originally Began Operation: 02/25/94
1.9 Date(s) of Facility Expansion(s) (if applicable):
2. OPERATION INFORMATION:
2.1 Facility No.: 31 (county number); 305 (facility number).
2.2 Operation Description: Swine operation
Wean to Feeder
5200- Certified Design Capacity
Is the above information correct? 0'yes; Elno. If no, correct below using the design capacity of the facility
The "No. of Animals" should be the maximum number for which the waste management structures were designed.
Type of Swine No. of Animals Tyne of Poultry No. of Animals TyM of Cattle No. of Animals
• Wean to Feeder • Layer • Dairy
• Feeder to Finish • Non -Layer • Beef
• Farrow to Wean (# sow) • Turkey
• Farrow to Feeder (# sow)
• Farrow to Finish (# sow)
Other Type of Livestock on the farm: No. of Animals:
FORM: AWO-G-E 5/28/98 Page 1 of 4 31 - 305

3.
2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): S I.2 fd109'- ; Required Acreage (as listed in the AWMP); 6 , 2
2.4 Number o lagoon storage ponds (circle which is applicable): _'2
2.5 Are subsurface rains present within 100' of any of the application fields? YES or NO (please circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? S or NO (please circle one)
2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, NRCS Standards, etc.) (Swine Only)
YES or NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited? — Q 3
What was the date that this facility's land application areas were sited? ' 'C1 3
REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit application
for animal waste operations.
The CAWMP must include the following components. Some of these components may not
have been required at the time the facility was certified but should be added to the
CAWMP for permitting purposes:
3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application.
3.3.4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application field.
3.3.8 The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.3.10 A site schematic.
3.3.11 Emergency Action Plan.
33.12 Insect Control Checklist with chosen best management practices noted.
3.3.13 Odor Control Checklist with chosen best management practices noted.
3.3.14 Mortality Control Checklist with the selected method noted.
3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility.
3.3.16 Operation and Maintenance Plan.
If your CAWMP includes any components not shown on this list, please include the
additional components with your submittal.
Applicants Initials
10,
FORM: AWO-G-E 5/28/98 Page 2 of 4 31- 305

to
Facility Number: 31 - 305
Facility Name: B&O Farm
4. APPLICANT'S CERTIFICATION:
I, Q K v er Qt/ Ax W (Land Owner's name listed in question 1.2), attest that
this application for i3 d- 0 b em (Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be returned to me as incomplete.
Signature Date 0
5. MANAGER'S CERTIFICATION: (complete only if different from the Land Owner)
(Manager's narrie listed in question 1.6), attest that this
application for (Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be returned as incomplete.
Signature
Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
1617 MAIL SERVICE CENTER
RALEIGH, NORTH CAROLINA 27699-1617
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
FORM: AWO-G-E 5128/98 Page 3 of 4 31 - 305

0
DIVISION OF WATER QUALITY REGIONAL OFFICES (1198)
Asbevilk Regional WQ Supervisor
59 Woodfin Place
Asheville, NC 29801
(sag) 251-0208
Fax (a -a} 251-6452
Avery Macon
Buncombe Madison
Burke
McDowell
Caldwell
Miubell
cb =1=
PC!k
Clay
Rutberford
Graham
Swain
Haywood
Transylvania
Henderson
Yancey
Iacksan
Fayetteville Regional WQ Svpervisot
Wachovia Building, Suite 714
Fayetteville, NC 29301
[phone]
Fax [phone]
Washington Regional WQ Supervisor
943 Washington Square Mall
Washington, NC Z7989
(25z)946-W I
Fax (; 975-3716
Burt Tales
Bertie Lanoir
Cbowan
Pamlico
Craven
Pasquotank
Muck
Perquimans
Date
Pict
Gates
Tyr,e11
Greene
Washington
Hertford
Wayne
Hyde
Mooresville Regional WQ Supervisor
919 North Main Street
Mooresville, NC 28115
[phone]
Fax [phone]-- 0
Raleigh Regional WQ Supervisor
38W Bat rert Dr.
Raleigh, NC Z7611
[phone]
Fax [phone]
Chatham
Nash
Dtatiam
Northampton
Edgecombe
Franklin
Orange
Pe=zon
Grsaville
Vance
Halifax
Wake
ioimston
Ww=
Lee
Wilson
Wilrnington Region. WQ Supervisor
127 Cardinal Drive Extension
Wilmington, NC 2U05-3845
[phone]
Fax [phone]
Anson Moore Akmander Uncola Brunswick New Hanover
Black- Richmond Csbatrus Meckkaburg Carteret Onslow
Cumberland Robeson Catawba Rowan Columbus Noder
Harnett Sampson Cleveland Sternly Duplin
Hoke Scotland Gaston Union
Montgomery buku
Wmstna-Salem Regional WQ Supervisar
595 Waugbtown Str*=
Vr=wn-Salem NC Z7107
Wi.b 7714600
Fix GIL) 771-4631
Alacc Rockingham
Allegheny Randolph
Ashe
Stokes
Caswell
Surry
Davidson
Watauga
Davie
Wilkes
Forsyth
Yadkin
Crui ferd
FORM: AWO-G-E &2 &98 Page 4 of 4

CT-
`-� eQ 0.t
Name' of .f (Fleas
;r.• .•.' Phone Na. =i91j�) 9=73iQ r
Fay ' location: •Latitude :and . Lorxgituce-c� a. 3 `� '/� �' (reii reajY. Also,.
Please 'attach. a cony of: .a. county. road"ma:p with location- identified.
T✓pe of operation (swine, -layer,
dairy,' -.etc.) :
Desic•n••'-capaci ty (nua= er of animals): 1,00v.► — err
Averace size of cperatleri (12%month .population, avg.) : 2k6 OQ
tverzge acreage needed for_land application of waste (acres): �I
--c_=c-==c--c�.�co�=_caste :� :�==cam=Ica=o=m�caca==n==cxrc-ace=c�c=�=-sac=cccccc=a
mac__eaI Spae'_a1<st Cam i_i eatioa . - -
As a technical specialist . designated by- the North Carolina Soil.. ' ana water
Conservation Cora-sissicn pursuant to 15A NCAC 6i .0005, I certify that the new -or
expanded animal waste management system as installed for the farm named above
has an animal waste management plan_ that meets the design, constrt:ction,
operation and maintenance.- standards and. spec_Fications of"the Division of
azviror=ental t4anageme'nt and the USM-Soil Conservation Service and/or the-.Ncrth
Carolina Soil and water Cons.eriration Commission pursuant to -15A NCAC 2H. 0217 and
15.E NCAC 67 -0001-.0005. The Following e7em'ents and their cor esponding, .minimum
criteria -ha hee. yerif?ed by me or other designated technical specialists and
are included in the plan as- applicable: minimum separations (buffers)-; liners or
equivalent for lagoons or waste storage ponds; waste storage capacity; adequate
quantity and amount of land for -waste utilization (or use of third pasty), .access
or o-nership of proper waste application equipment; schedule for -timing of
applications; application rates; loading rates; and the control of the discharge
of pollutants from stor=,aater runoff events less severe than the 25-_year, .24-hour
stora.
'YP---a of IT ect�i a1 Specia7,iat (Please
a£fi? iation- ic!
Address (Agee o / Phone No . G
3
Signature: l_- Date: 9
=c�accc-�cv--- c---=-sacca3ass ac c=mac ao �•=�cc===as=c-�acco..ccc-�tcca=aa
GWZar /LIaaaga=
1 (we) understand the operation and established in the
approved animal waste management plan fQr A r+ ".above and will implement
da—
' .ice
these procedures_ I (we) ,know that any -a�k - ��,►Expansion to the existing
design capacity of the wash treatment and storage system or construction of new
facilities will require•a new certification to be submitted tp the.Division of
Environmental N.anagement before the new animals are stocked. I (we) also
understand that there must be_no discharge of animal waste from this system to
surface waters of the state either through a man-mP-de . cvnve_va*ice- or through
-unoff from a storm event less severe .than the 2S-ye2, . 2-4-hcur storm. The
anprovec plan will be •£fled at the farzi and at the office of the local Soil and
water Conservation District_ L
:;gin cf Land oarcar (Please Print) 0 1 1 VC-c -014F10, uJ
Signature:' Date: t
%T=Q of ►'Mmage=, if different from owner (Please print) : hr\
Signature: Date: ZS Q4
�- A chan6le in land o---�Oshipfrequires notification or a new certification
(if the approved. plan is changed) to be submitted to the Division of
Environmental Management within 60 days of a title transfer.
DEd USE ONLY: ACNc•r; # IV 0000 4

1+-, �p� t C r �+^ Ru • ' ti'4 •r• r ` `� - � C ` � R �y yp
i43 c
a -
40
y L • � + r� a l� i
r qq
� � i Ci 4' � ` li � •� � r\ fr tE`
r p } C
K •` t r � � Z � L t
�
€ . . If .� _
4 -Sr
Q• '
b �1 •\ Vrni - •J�_n Y � t ter'.
_ •vsS
4
_ r L
r f
tt �i
piomVLAST
L Le
t i «h CC
q • S {
Rp .. • r.r t �j i i _ C � r L
i = Jf � ��• r ;i. �, ti ` rw i L., pp p r � r - yt C «
r\
fi FE R rCC r CC r r i r' • 9t b r
&~ y G
4. {'� J i•
ver D LA
. s C' „ '
1 -b^1

. DUPLIN SWCD TECENICAL REVIEW OF SWINE
CERTIFICATIONS PERFORMED BY NON NRCS OR DISTRICT
STAFF
NAME: awe-, n,,ge"
DATE RECEIVED: �' 3
SIZE AND TYPE OPERATION:
SWINE INTEGRATOR:
TECHNICAL SPECIALIST: ,pl
All plan documents have been received in SWCD office.
�G Waste plan appears adequate
�G Design was completed by NRCS
Design was completed by PE and not reviewed by NRCS C^ZjL,
Does the design package contain the following components and does each appear to be
addressed properly according to NRCS Technical Guide standards.?
Collection
-� Storage
Treatment
--� Operation and Maintenance (Land Application)
WAS A FIELD REVIEW PERFORMED BY SWCD STAFF 22
WAS THIS REVIEW BASED SOLELY ON THE DOCUMENTS SUBMITTED BY THE
TECHNICAL SPECIALIST:
REVIEWER'S SIGNATURE:
DATE: �¢

USDA SOIL CONSERVATION SERVICE
FINAL CONSTRUCTION CHECK AND CERTIFICATION ,
FORANTMAL�IVASTE'TREATMEN'I=-L'AGOON-(359)
E :t� � r -• i - `.
NAME j iyfr .�f�i i-iQY✓ x _
LOCATION
SIZE OF OPERATION FARROW. TO- FEEDER .
FARROW TO FINISH
FARROW ;TO WEAN
CONTRACTING COMPANY -" FEEDER TO FINISH
WEAN -TO FEEDER
OTHER
DESIGN DATA AND CONSTRUCTION CHECK DATA :
.TBM ELEVATION FEET
AS DESIGNED • AS BUILT.
INSIDE TOP DIMENSION
DIKE TOP WIDTH
1-2-• a
TOP OF DIKE
BOTTOM OF LAGOON
INSIDE SIDESLOPE
OUTSIDE SIDESLOPE
3 I
PIPE INTVERT
CLAY LINER/CORE TRENCH
13 6 x !�-1• �-
HAS LAGOON BEEN SEEDED TO PERMANENT VEGETATION YES , NO
DOES LAGOON MEET SCS MINIMUM STANDARDS AND SPECIFICATIONS FOR
WASTE TREATMENT LAGOONS AS OUTLINED IN PRACTICE CODE :I59?
YES
COMMENTS
SIGNATURE
NO
TITLE
DATE

United States Soil
s Department of Conservation
Agriculture Service
Date 16 ` S— 93
P. O. Box 277
Kenansville, NC 28349
Telephone [phone]
Dear r.
Enclosed is your lagoon design prepared by (Jce ar Aor rpm .r . c and reviewed
and approved by the Soil Conservation Service.. -This lagoon, as designed, meets SCS
standards and specifications. It is the responsibility of the contractor and you to build the
lagoon according to the design. You should contact the swine company to get assistance in the
layout of the lagoon for construction. If you have any questions during construction, please
contact this office or the swine company.
Please be aware that SCS has not checked the excavation and fill volumes of dirt. The swine
company has computed these figures and any questions regarding the amount of excavation
should be directed to the company. SCS does not certify that excavation and till volun}es are
correct.
If you would like for the SCS,to certify that the lagoon has been built to design specifications
and meets SCS specifications and standards, personnel from this office will need to conduct a
final construction check prior to animal waste being put in the lagoon. State law requires that
new and expanded operations have lagoons that meet the SCS minimum design specifications.
In order to certify the lagoon, .we must get bottom elevations as well as top of dike and
sideslope readings. If given a few days notice, we will try to schedule the construction check
prior to the contractor leaving the site; however, since we schedule several days in advance, it
is best if you let us know as soon as possible when you believe that a construction check will
be needed.
Also enclosed is a contractor certification that must be signed by the contractor once the
lagoon is completed. We need this form returned to us before we certify that the lagoon
meets our specifications. You may want to inform your contractor prior to beginning the
job that you will need him to certify his work meets the design requirements.
If you have any questions concerning this design or the accompanying waste utilization plan.
please contact us.
Sincerely,
rst
Michael E. Sugg
District Conservationist
O The Soa conservation service
lJis an agency of the
Department of Agriculture

Ju`�Rse,�
BEFORE BEGINNING EXCAVATION � '
LANDONER IS ADVISED TO CONTACT
W
ULOCO TO ASSURE Ti AT UNDERGROUND
L/ UTILITIES ARE NOT DESTROYED
1-800-632-4949 I
SCS DOES NOT CERTIFY
THAT EXCAVATION AND
FILL VOLLTWS ARE
CORRECT
o
e
C4Ca�i
f J Lr N c3
AV r" j v g vt-
ocox s t s Lap 4 L,#4 Ft �7-4EOJ LfL-j 1;�
cLA7 • PAC''`
9�- 20-g3
to a

Operator:OLIVER OUTLAW County: DUPLIN Dater 09/22/93
Distance to nearest residence (ether.than owner): 1000.00 feet qoa
1. STEADS` STATE LIVE WEIGHT
0
sews
(farrow to
finish)
..
1417
lbs. -
0
lbs
0
sews
(farrow to
feeder)•
x
522
lbs. —
0
lbs
0
head:
(finishing
only)
x
135
lbs. —
0
lbs
0
sews
(farrow to
mean)
..
433
lbs. --
0
lbs,
2600
head
(wean to feeder)
x
30
lbs. =
78000
lbs
TOTAL
STEADY STATE
LIVE
WEIGHT
(SSLW) =
78000
lbs
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 78000 lbs. SSLW x Treatment Volume (CF) / l b . SSLW
Treatment Volume(CF)/lb. SSLW= 78000 CF/lb. SSLW
Volume = 78000 cubic feet
3. STORAGE VOLUME FOR SLUDGE'ACCUMULATION
Voltmme = 0.00 cubic feet
Q
, bC,
4. TOTAL_. DESIGN VOLUME
Inside top length 150.00 feet ;
Inside top width 125.00 feet
Top of dike at elevation 46.00
feet
Freeboard 1.30 feet ; Side slopes
2.50 : 1 (inside lagoon)
Total design lagoon liquid level at
elevation 44.70 feet
Bottom of lagoon elevation 32.50
feet
Seasonal high water table elevation
45 OO- feet
3 a. o 3 WAR".
Total design volume using prismeidal
formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH
2.5 2.5 2.5 2.50
143.5 119.5 12.20
AREA OF TOP
LENGTH * WIDTH =
143.5 118.5 1?005 (AREA OF TOP)
AREA OF BOTTOM
LENGTH * WIDTH =
82.5 51.5 4744 (AREA OF BOTTOM)
AREA OF MIDSECTION
LENGTH WIDTH * 4
113.0 99.0 39776 (AREA OF MIDSECTION * 4)
CU. FT. = [AREA TOP + (4*AREA MIDSECTION) f AREA BOTTOM] * DEPTH/6
17004.8 39776.00 4743.7 2.
VOLUME OF LAGOON AT TOTAL DESIGN LIQUID LEVEL = 125100 CU. FT.

a. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
150.0 125.E l e?50 . 0 square feet
Buildings (roof and lot water)
Length * Width =
0.00 0. oo 0.0 square feet
TOTAL DA 18750.0 square feet
Design temporary storage period to be
IE30 days.
5A. Volume of waste produced
Approximate daily production of manure in
CF/LP SSLW 0.00136
Volume = 78000 Lbs . SSLW * CF of Waste/Lb
. /Day aF 180 days
Volume = 19094 cubic feet
.JET . Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh :grater used for a flush system.
Flush systems that recirculal
the lagoon water are accounted for in 5A.
Volume = 0.0 gallons/day
18C) days storage/7.48 gallons
per CF
Volume = 0.0 cubic feet
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds
evaporation by largest amours-
le(7) days e.•.cess rainfall -
7.0 inches
Volume = 7.0 in DA / 12 inches per
foot
Volume = 10?37.5 cubic feet

5D. Volume . of 25 year -- C 4 hour storm
Volume = 7.5 inches / 12 inches per fact DA
Volume = 11718.8 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 19094 cubic feet
5S. U tunic feet
5C. 10938 cubic feet
5D. 11719 cubic feet
TOTAL 41751 cubic feet
6. SUMMARY
Total required volumes 119751 cubic feet
Total design volume avail. 125100 cubic feet
Min. req. treatment volume plus sludge accumulation 78000 cubic fe
At elev. 41.60 feet ; Volumes is 72431 cubic feet (end pumping)
Total design volume less 25yr--24hr storm is 113381 cubic feet
At elev. 43.90 feet ; Volume is 111911 cubic feet (start pumping
31.02 ,r.'4
Seasonal high water table elevation 45vow, feet /
7. DESIGNED BY: � ` �F'PFcOVED 6Y ; � � � Al'-
DATE: DATE: 1J 4 • i3
SCS DOES NOT CERTIFY
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN THAT EXCAVATION AND
FILL VOLUMES ARE
coMr�EriTs : ---------------------------------- CORRECT

OPERATION AND MAINTENANCE FLAN
------------------------------
This lagoon is designed for waste treatment (permanent storage) with
rain. odor control, The time required for the planned fluid level to be
reached (permanent + temporary storage) may vary due to sail conditions
flushing operations, and the amount of fresh water added to the system.
The designed 6 months temporary storage is an estimated volume
based on; 1) waste from animals; �!) excess rainfall after evaporation;
and 31 the largest 24 hoar (one day) rainfall that occurs on the
aver -age of once every 25 years. The volume of waste generated from
a given number of animals will be fairly constant throughout the year
and from year to year. This estimate is based on 7 inches of excess
rainfall which is equal to or exceeds the highest 6 months excess in
a year. The average annual excess rainfall is approximately 9 inches.
Therefore, an average of S inches of excess rainfall will need to be
pumped each year. The 25 year rainfall will not be a factor to consider'
in an annual pumping cycle, but this storage volume must always be
available. A maximum elevation is determined in each design to begin
pumping and this is usually the cutlet invert of pipe(s) from
building(s). If the outlet pipe is not installed on the elevation to
begin pumping, a permanent marker must be installed on this elevation
to indicate when pumping should begin. An elevation must be established
to step pumping to maint.1in minimum treatment depth (6 feet).
Pumpinq can be started or stopped at any time between these two
elevations for operating convenience as site conditions permit, such as
weather, soils, crop, and equipment in order to apply waste without
runoff or leaching.
Land application of waste water is recognised as an acceptable
method of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying wa�5te to prevent damage to craps.
The following items are to be carried out;
1. It is strongly recommended that the treatment lagoon be pre -
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times. When pre'charging is complete,
flash buildings with recycled lagoon liquid. Fresh water shoLtld not
be used foj- flushing after- initial filling.
2. The attached waste utilisation plan shall be followed. This
plan recommends sampling and testing of waste (see attachment)
before land application.
3. Begin pump -out of the lagoon when fluid level reaches eleva-
tion 43.90 as marked by permanent marker. Stop pump --out when
the fluid level reaches elevation 41.60 or before the fluid depth is
less than 6 feet deep (this prevents the. loss of favorable
bacteria). The design temporary storage, less 25 year storm
is 30032 cubic feet or 224639 gallons. As stated before, this
volume will vary considerably from year to year.

4. The recommended maximum amount to apply per irrigation'is
c+ne (1) inch and the recommended maximum application rate is 0.3
inch per -hour.
5. Keep vegetation on the embankment and areas adjacent to the
lagoon mound annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
outlets.
S. t`:eep a minimum of E5 feet of grass vegetated buffer around
waste utilization fields adjacent to perennial streams. Waste will
not be applied in open ditches. Do not pump within 200 feet of a
resi:fence or within 10-0 feet of a well.
9. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.

State of North Carolina RECIT LIC
Department of Environment ` • o
and Natural Resources NM 17
zo
Division of Water Quality
BY:
James B. Hunt, Jr., Governor
Bill Holman, Secretary NCDENR
Kerr T. Stevens, Director NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOEJRCES
March 15, 2000
CERTIFIED MAIL
RETURN RECEIPT REOUESTED
Oliver Outlaw
B&O Farm
1769 Wards Bridge Rd
Warsaw NC 28398
Farm Number: 31 - 303
Dear Oliver Outlaw:
You are hereby notified that B&O Farm, in accordance with G.S. 143-215.10C, must apply for coverage under an
Animal Waste Operation General Permit. Upon receipt of this letter, your farm has sixty (60) days to submit the attached
application and all supporting documentation. In accordance with Chapter 626 of 1995 Session Laws (Regular Session
1996), Section 19(c)(2), any owner or operator who fails to submit an application by the date specified by the
Department SHALL NOT OPERATE the animal waste system after the specified date. Your application must be
returned within sixty (60) days of receipt of this letter. Failure to submit the application as required may also subject your
facility to a civil penalty and other enforcement actions for each day the facility is operated following the due date of the
application.
The attached application has been partially completed using information listed in your Animal Waste Management
Plan Certification Form. If any of the general or operation information listed is incorrect please make corrections as noted on
the application before returning the application package. The signed original application, one copy of the signed application,
two copies of a general location map, and two copies of the Certified Animal Waste Management Plan must be returned to
complete the application package. The completed package should be sent to the following address:
North Carolina Division of Water Quality
Water Quality Section
Non -Discharge Permitting Unit
1617Mail Service Center
Raleigh, NC 27699-1617
If you have any questions concerning this letter, please call J R Joshi at [phone] extension 363 or Dean
Hunkele with the Wilmington Regional Office at [phone].
Sincer ,
f
for Kerr T. Stevens
cc: Permit File (w/o encl.)
Wilmington Regional Office (w/o encl.)
1617 Mail Service Center, Raleigh, NC 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50%, recycled/ 10% post -consumer paper

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
Oliver Outlaw
B &O Farm
1769 Wards Bridge Rd
Warsaw NC 28398
Dear Oliver Outlaw:
/ • •
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
December 30, 1999
Subject: Fertilizer Application Recordkeeping
Animal Waste Management System
Facility Number 31-305
Duplin County
This letter is being sent to clarify the recordkeeping requirement for Plant Available Nitrogen (PAN)
application on fields that are part of your Certified Animal Waste Management Plan.
In order to show that the agronomic loading rates for the crops being grown are not being exceeded, you
must keep records of all sources of nitrogen that are being added to these sites. This would include nitrogen
from all types of animal waste as well as municipal and industrial sludges/residuals, and commercial fertilizers.
Beginning January 1, 2000, all nitrogen sources applied to land receiving animal waste are required to
be kept on the appropriate recordkeeping forms (i.e. IRR1, IRR2, DRY), DRY2, DRYS, SLUR], SLUR2,
SLD1, and SLD2) and maintained in the facility records for review. The Division of Water Quality (DWQ)
compliance inspectors and Division of Soil and Water operation reviewers will review all recordkeeping during
routine inspections. - Facilities not documenting all sources of nitrogen application will be subject to an
appropriate enforcement action.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Ms. Sonya Avant of the
DWQ staff at [phone] ext. 571.
Sincere)
Kerr T. Stevens, D/ �e7
irector
Division of Water Quality
cc: Wilmington Regional Office
Duplin County Soil and Water Conservation District
Facility File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

02/2611990 00:46 9102960159 SUMMERLIN FARMS PAGE 01
�roe.tfm
Summerlln Farms, Inc.
2473 W. Wards Bridge Rd. Warsaw, N. C. 28398
910-296-0158 fax To: Brian L. wrem
91.0-296-0312 office Company w-DU R, Wihnin � Office
Phone: gia�5-s�oo
914-29�-f I24 dome Fax: 910-35a2004
drummer
Oduplinneuom From: mmerlin
e-�I Title:
President and Operator in Charge
Extension:
Date: February 25th 1998
Pages Including This Cover Page 0
Notes:
This latter is in reference to certified mail #Z312 648 617
concerniog facility number 31-303

02/26/1998 00:46
9102960159
SUMMERLIN FARMS
PAGE 02
/910/29603f2 ej�v
/91G/ 2961124 Xw
Februazy 24, 1998
ffitmmertin.ga`rms, Inc.
2473 %1 ryWII.f Srfdpr 96
11{Wv. Awtf Vw4 m 28398
To: State of North Carolina
Department of Environment and Natural Resources
Wihni g on Regional Office
127 North Carolina Drive
Wihntington, North Carolina 2840$
Attu.: 14L Brian L_ Wrenn
Faviroruaental Speoi.alist
Re: Certified Mail #Z312 648 617
DINIF W. WrOan:
19IW 296OIM 94
dswmrrrCaVupd&vf,mm •mail
'ibis letter is to inform you of what steps have bccu already tdwn to correct the deficiencies which were
noted along with those steps which will be takes is the near future to oomplcte the con=Uom.
1) hrWhion pipes have been repaired and are currently working properly
2) Lagoon currently exceeds the state specifications of 19 inches.
3) All ponded waste has been pumped back into the lagoon.
4) The amsio n cuts which were noted will be f tled with sandy clay, packed and
reseeded.
5) All trccs on the lagoon dime wall have been cut and will be removed.
6) All root systerus of the above trees will be removed and holes will be filled
with sandy clay, packed and then reseeded.
We com>racted our local Soil and Water Conservation office for recommendations and requested a visit
from an itxs wor. They have visited the site and their recommendations concur with the above actions.
We will complete the above repairs within the next ninety days with weather permitting. We will keep you
infnnocd, in writing, as to when each step has been completed.
Please let us Imow if there are any iCw Cher obligations which we need to fulfill or ifyou have nay furdw
recommendations which you feel would' prov our waste managemem
Sincemly,
Lewis 3 suotlu martin

State of North Carolina
Department of Environme
Health and Natural Resou CIvJ997'
Division of Water Quality NOV
James B. Hunt, Jr., Governor BY:
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
November 14, 1997
MEMORANDUM
TO: Wilmington Regional Water Quality Supervisor
FROM: Sue Homewood v�
SUBJECT: Notification of Facility Number Change
The following changes have been made to the Animal Operations Database. Please make
appropriate changes in your files.
Facility numbers 31-305 and 31-799 were combined under one facility number; 31-305.
Facility number 31-799 was deleted from the animal operations database.
Facility numbers 31-783 and 31-793 were combined under one facility number; 31-783.
Facility number 31-793 was deleted from the animal operations database.
Facility numbers 31-834 and 31-840 were combined under one facility number; 31-834.
Facility number 31-840 was deleted from the animal operations database.
If you have any comments or questions please feel free to call me at [phone] ext 502.
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

State of North Carolina
Department of Environment,
Health and Natural Resources
James B. Hunt, Jr., Governor
Jonathan B, Howes, Secretary
November 13, 1996
Oliver Outlaw
Oliver Outlaw Farm
1769 Wards Bridge Rd
Warsaw NC 28398
SUBJECT: Operator In Charge Designation
Facility: Oliver Outlaw Farm
Facility ID#: 31-305
Duplin County
Dear Mr. Outlaw:
Senate Bill 1217, An Act to Implement Recommendations of the Blue Ribbon Study
Commission on Agricultural Waste, enacted by the 1996 North Carolina General Assembly,
requires a certified operator for each animal waste management system that serves 250 or more
swine by January 1, 1997. The owner of each animal waste management system must submit a
designation form to the Technical Assistance and Certification Group- which designates an
Operator in Charge and is countersigned by the certified operator. The enclosed form -must be
submitted by January 1, 1997 for all facilities in operation as of that date. Failure to designate a
certified operator for your animal waste management system is a violation of 15A NCAC 2H
.0224 and may result in the assessment of a civil penalty.
If you have questions concerning operator training or examinations for certification, please
contact your local North Carolina Cooperative Extension Service agent or our office.
Examinations have been offered on an on -going basis in many counties throughout the state for
the past several months and will continue to be offered through December 31, 1996.
Thank you for your cooperation. If you have any questions concerning this requirement please
call Beth Buffington or Barry Huneycutt of our staff at 919/733-0026.
Sincerely,
A. Pres ow r., .,Dire or
Division of Water Quality
Enclosure
cc: Wilmington Regional Office
Water Quality Files
P.O. Box 27687.
Raleigh, North Carolina 2761 1-7687 NvfCAn Equal Opportunity/Affirmative Action Employer
Voice 919-715 a100 50% recycled/10% post -consumer paper

SPECIFICATIONS FOR CONSTRUCTION OF WASTE TREATMENT LAGOONS
----------------------------------------------------------
Clearing:
All trees and brush shall be removed from the construction area
before any excavating or fill is started. Stumps will be removed
L-:ithin the area of the foundation of the embankment and fill areas
and all excavated areas. All stumps and roots exceeding one (1.)
inch in diameter shall be removed to a minimum depth of one (1)
foot. Satisfactory disposition will be made of all debris. The
foundation area shall be loosened thoroughly before placement of
embankment material. Lagoon site (and pad site if needed) to be
stripped of topsoil (3") and stockpiled for use on dike and pad
slopes (R-S"). The topsoiling quantity is in excess of amounts
specified on page One (1) .
Cut-off Trench:
----------------
A cut-off trench (when specified) shall be installed as shown in
the plans.
Construction:
Construction of excavated and earthfill areas shall be performed to
the neat lines and grades as planned. Deviations from this will
require prior approval of the SCS. Earthfill shall.be placed in
max. of 6" lifts and not placed in standing water. Compaction shell be
performed by the construction equipment or cheeps --foot roller during
placement. The embankment of the lagoon shall be installed using
the more impervious materials. Construction of fill heights shall
include ten (10) percent for settlement. To protect against ,seepage,
when areas Of uj-Isuitable material are encountered, they will need to
be excavated a minimum of one (1) foot below grade and backfilled and
compacted ;with a SCS approved material (ie-CL,SC,CH). Refer to the soil
investigation information in the plans for special considerations.
Precautions should be taken during construction to prevent excessive
ey-osi.an and sedimentation.
Vegetation:
All exposed embankment and ether bare constructed areas shall be
seeded to the planned type of vegetation.as soon as passible after
construction according to seeding specifications sheet.

SEEDING RECOMMENDATIONS
-----------------------
AREA TO BE SEEDED: 3.0 ACRES
USE THE SEED MIXTURE INDICATED:
190 LBS. FESCUE GRASS @ 60 LBS./ACRE
(BEST SUITED ON CLAYEY OR WET SOIL CONDITIONS)
SEEDING DATES: SEPTEMBER 15 TO NOVEMBER 30
0 LBS. 'PENSACOLA' BAHIA GRASS @ 60 LBS./ACRE
(SEE FOOTNOTE NO, 1)
SEEDING DATES: MARCH 15 TO JUNE 30
it LBS. HULLED BERMUDA GRASS @ B LBS./AC.
(SUITED FOR MOST SOIL CONDITIONS)
SEEDING DATES: APRIL 1 TO JULY 31
0 LBS. RYE GRAIN @ 30 LBS./ACRE (NURSERY FOR FESCUE)
1.20 LBS. RYE GRASS @ 40 LBS./ACRE (TEMPORARY VEGETATION)
SEEDING DATES: DECEMBER 1 TO MARCH 30
LBS.
APPLY THE FOLLOWING :
3o00 LBS. OF 10-10-10 FERTILIZER (1000 LBS./ACRE)
6 TONS OF DOLOMITIC LIME (2 TONS/ACRE)
300 BALES OF SMALL GRAIN STRAW (100 BALES/ACRE)
ALL SURFACE DRAINS SHOULD BE INSTALLED PRIOR TO SEEDING. SHAPE
ALL DISTURBED AREA IMMEDIATELY AFTER EARTH MOVING IS COMPLETED.
At --'FLY LIME AND FERT I L I ?ER THEN DISK TO PREPARE A 3 TO 4 INCH
st,100TH SEEDBED. APPLY SEED AND FIRM SEEDBED WITH A CULTIPACFER
OF: SIMILAR. EQUIPMENT. APPLY MULCH AND SECURE WITH A MULCH
ANCHORING TOOL OR NETTING.
1. PENSACOLA BAHIAGRASS IS SLOWER TO ESTABLISH THAN COMMON
BERMUDA GRASS. WHEN USING BAHIA, IT IS RECOMMENDED THAT B
LESS./ACRE OF COMMON BERMUDA BE INCLUDED TO PROVIDE COVER
UN-F►L BAHIAGRASS-I5 ESTABLISHED.

'roTl� G C4f u 38'u C y
Voluent .ES4'm,ieS
FFIi
p;k,— IVIO C�
Pia 1 27? ey
T0412.1 36�r.cY
Gui o
Typical Cross Section
LOW" Wer �� c. � .ItJ.
P; Pe Cu41t.y r rcv.
L41. 6
Slop', �.S
�F.r+•.,�,• _��.•:,�.` _Icy
J
3.9
�r
erm `.7ory4�, � •, w.J.
004
cjUJ. . c1

w■■iiG■■'L/#w/■���el'.]■!<ii�Y/r,�:i■■■l4L�DCl�■##■vC!
■EEEE■■sw■>rwwiwi+�■��■■■a■w■■■ri■w■■■■■wi■■■!■
■i■■■!■!i!!■■i■!!/■ii■liil■i!#■i■rii■■■!i■■■i■
SIMMENEEMOM
MEMENEEMEN
■MEM/ #E/■
NUNN WERE
■EES!/■■■E
■EE■E■■ww/
mmussommom
■Eiw:1JtAls
E■■1R■/i■E■
■■iaE■/wE■
MOMMEMEMSE
ommusummus
■1<1EMiE■■i
MrAmommmom
ESQS■■SEEM

f�- United States Soil P. 0- Box 277
Department of conservation Kenansville, NC 28349
Agricutture Service Telephone [phone]
WASTE MANAGEMENT FACILITY SITE EVALUATION
GENERAL ffORMATION�
NAME L & LOCATIONS, R. 1 3 d D
TELEPHONE__, �,3 r,_� SIZE OF OPERATION Z(1
LOCATION DATA
Q r
DISTANCE FROM NEAREST RESIDENCE NOT OWNED BY PRODUCER Q S-
NUMBER OF HOUSES WITHIN 2000 FEET OF SITE j
IS SITE WITHIN 100 YEAR FLOOD PLAIN? YES NO
IS SITE AT LEAST 100 FEET FROM A "BLUE LINE" PERENNIAL STREAM? YES NO
IS SITE WITHIN 1 MILE ZONING JURISDICTION OF A MUNICIPALITY? YES NO
if yes, landowner should consult with local zoning board about required permits
WETLANDS \ _
WILL SITE INVOLVE CLEARING WOODLAND OR ANY NON CROPLAND? YES NO
IF YES, HAS PRODUCER COMPLETED AN AD-1026 FORM? YES NO
DOES NON WETLAND NEED TO BE MEASURED BY REGISTERED SURVEYOR PRIOR TO
APPROVING WASTE MANAGEMENT PLAN YES NO
IF WETLANDS ARE INVOLVED, IT IS THE RESPONSIBILITY OF THE PRODUCER TO CONTACT THE US
ARMY CORP OF ENGINEERS AND THE NC DIVISION OF ENVIRONMENTAL MANAGEMENT TO
DETERMINE IF ADDITIONAL PERMITS ARE REQUIRED. NO WETLANDS SHOULD BE ALTERED UNTIL
PRODUCER RECEIVES WRITTEN APPROVAL FROM SCS, US ARMY CORP OF ENGINEERS AND NC
DIVISION OF ENVIRONMENTAL MANAGEMENT.
WASTE N ANAGENIENT -- VALID ONLY IF WASTE NIANAGEMENT PLAN ATTACHED
DOES PRODUCER OWN ENOUGH LAND TO PROPERLY LAND APPLY WASTE? YES NO
IF NO, DOES PRODUCER HAVE ACCESS TO MORE LAND? YES NO
SEE ATTACHED PLAN FOR SPECIFIC RECOMMENDATIONS
SOIL. rWESTIGATION -- VALID ONLY IF SOIL LNVESTIGATION SHEET ATTACHED
IS SOIL SUITABLE FOR LAGOON? YES NO
IS A CLAY LINER REQUIRED? YES NO
iF YES, 1S CLAY AVAILABLE ONSITE? YES NO QUESTIONABLE
IS A CORE TRENCH REQUIRED? YES NO`-..,
SITE ,APPROVED YES NO CONDITIONAL
j CONIIIIENT &4'K-C .
11 �� '4--�� e5l A S a o A,—
APPROVAL BASED ON SCS STANDARDS VALID FOR 60 DAYS FROM DATE SIGNED. 71US APPROVAL
SUBJECT TO CHANGE BASED ON CHANGES IN NATIONAL, STATE, OR LOCAL LEGISLATION.
ripe or�0«�UTerve��,T4e 7 0 FEET FROM RESIDENCE AT TIMES OF DESIGN.
Uepar7ment ct Aaricutt:e:e SIGNATURE_

- � ZONE A -
1301
Na hung 0:
:.G 1
i
11
�1 i300
51
11 ..
= 1301
ZONE A.-
L
TT�•
ZONE X
13T9
1 .

US Department of Agriculture
Soil Conservation Service
NC -CPA 16
4-92
ENVIRONMENTAL EVALUATION
Land User OwnerL} O ' / _ County
Location/Tract & Field Number.. a1 2 D F I a Acreage�.s
Prepared by 6-�cs�� _ - - -Date— 2.3 -�_
V
Brief Description of Planned Practice/RMS/Project Measure:
Lg- 5 a 4m n� tf- Qua
Environmental Factors and Resources to Identify and Evaluate J
1. Is wetland included in the planning area: .(References: NCPM;
190-GM 410.26; Hydric soils list; Classification of Wetlands and
Deepwater Habitats of - the _ U.S_;. National Wetlands Inventory Maps;
NFSAM.
No
Yes - If yes,
I
-- Identify types present
-- Attach environmental evaluation showing what effect
planned assistance will have on wetland and how this
assistance is within policy
Have needed permits (CAMA, DEM, Corps, etc.) been
obtained_by the landuser?
-- Make sure no planned practices will put the landowner in
violation of Swampbuster
2. Endangered and/or threatened -species: .(References: 190-GM
\-410.22; Technical Guide Section I-i(13) and Section I-vii
y No Yes
-- Identify species --whose range --and habitat needs indicate
.they might occur in planning area
---- Identify on map any designated critical habitat

31. Is. a designated -natural or scenic area included in, the planning
area• or will. planned actions- impact. on an- adjacent-, natural or
scenic area? (References: 190-GM 410.23 and .24)
No
Yes. If 'yes, encourage landuser to. consult with concerned:
agencies:,, societies,. and. individu'als.: to.. arrive at
mutually. satisfactory land, use: and-. treatment-.,
7�
4-. Doesthe. plawring, area.- ixic-lude.- the!--10.Q;--yeaz,-
1
(References-.,: N.!CPM;, 1-9,-Q.-GM. HUD; lood,.. PI -a -in, ma
Yes. if. yes:,.
Is,, the- assist-ed- action: likely tQ. have: significant
adverse- effects: on-. existing. natural and, beneficial
values. in; the, flood pla-in?Is- there a practical. alternative: outside. the- flood,
plain? -
Has: the, -f1w&. pain, been used for agricultural
produqt.,-
r
ion, �fp- at - least. I- -Of' the.. -last. 5. years?-- -
5.. Is an: archaeological or historical. site- located., in- the. planning.,-
area?� (References-.. NCPM-;. 420-GM 4-01;- National Register- of
Historic: Places)-.
Ko:
Yes- - It- yes,: have. steps been. taken, to ensure- the
protection. of this area?.-
6, Are there any prime., unique, or locally important farmlands-. in
the operating unit?, (References: 310-GM).
No.
Yes - Zf yes, Identify, on:. -a soils map or- legend. Nb A
T. Will- the.. action- result. in. sodbustinq.?
No: Yes
a.. Will. the: action- result in. swampbusting?.
No Yes-
9,-.. Is there: a potential for. - c.ontroversy,!.;1_'-
Yes!
From. whom?: a

10_ Are permits required?/should the person contact.permit agencies?
No Yes
When an environmental factor or resource is identified on the
site, the user will refer to the appropriate reference for policy
and document the appropriate action in the notes portion of this
form.
NOTES, DOCUMENTATION, FOLLOW-UP
Zz: -

C
.y WS-ENG SU U. S OEPARTMEHT OF AGRICULTURE
f• Rw i,5-70.rt;�_._:�.W_� .._ 3�iL CdNSERVATIpN SERViCIE
� A.�;�,Z1���, r�� ��`•'i " �',_sijM r���.-:.t�,t, i €i,ts�; ,.` . � .� ...�.' .. ' , `N'_.,.�_.... c '-
SOIL IEVVES3IGATEOIV TOMDE7ERMINE YSUITEtBI_t=1if ;OF PROPOSED POND ,SITE,"
0T
� r
f � •
• • + s•
WATERSHED AREA ��ENTS
.O. i ACRES PASTURE- ACRES
WOODLAND- ACRES TOT•• i •• t•
OF f' i i i i SHOWING WHERE•
!■�!■0■®■!■®!■■®®!!!■■■■■SE
!■■
■■■
■■■■■■■■■■■■■N■■■
■■■R
'EW
=■■■■■■�■■■■■■■■■■■
ME■LAW
-------....E.........■■.....!■■■
■r■r■■.WMMMM.........�....
■■■■
OEM
■■■■■■■■■■■■■■■!■
BORING NUMBER AND PROFILE
Make and list dam -site and sollfway boringr fust - then panded area and borrow pit borfngS - Separate with wrffwt red llna
(Coritinued an bacA whery necessary) Shaw water table elevations an darn-sitc borings.
®IMMim!m!mioImi
:
i0
�'�#''il�f�',t'�''�['���'
■l■lel■leiel■i�l■I■i■l■;■4■4■
I�®!�il�l�i■i�!�i
■1■!■1■1■I®I■1■1■i■1■{!!■1■i■
E�33�'■i■I■,■!ii
I�■!■!■l�l■1■I�I■1■I■i■lel■1■f■
��'�■I■1■i■i■!■I��■i■l�l■I■ICI■I■�■■�■1■l�l■
��a��■ieleit!e�e�e
ei■i■I�l■i■1■i�iei■I■;■I!=�■i�l■
MW13■!■I■I!!�li�lle!elll
lam!■I■I■I■I■i■l
ie�■l■
C�7�!�i■1■i■
!■1■■Iel■Iri�i■1■i■lel■ielei■!rl■
y
�;�17�■I��■!�i�l■�■��■i■I■I■i■1■i�l■1■i■I■I■tl■I■
�'i!�!■I■!■i:'•�!�l■
I■I■lief■'■I■I■I■1■'■1■�■1el■
ilGis�,
i■�■I■i�i�i■�!■�■i■l■�■i■i■�i■i■�■l■I�irel
BORINGS MADE BY
Fr fi

U. S. Department of Agriculture r, NC-ENG-34
Soil Conservation Service �;- �; ..;��.� September 1980
w- - - File Code:'210
HAZARD CLASSIFICATION DATA SHEET FOR DAMS
Landowner 1 U. C^1 OLMkw -- _ 3 r s � County i,LAO
Community or Group No.= Conservation Plan No. `
Estimated Depth of Water to Top of Dam Ft. Length of Flood Pool Ft.
Date of Field Hazard Investigation �t- z6 9r3
Evaluation by reach of flood plain downstream to the point of estimated minor effect
from sudden dam failure.
. Est. Elev.:Est. evation
. Kind of :Improvements: of Breach
Reach: Length: Width: Slope: .Land Use Improvements : Above :Floodwater Above
Flood Plain: Flood Plain
Ft. Ft. X; Ft. Ft.
3
Describe potential for loss of life and damage to existing or probable future downstream
improvements from a sudden breach
Hazard Classification of DamQ b, c) (see NEM-Part 520.21)
Dam Classification (I,Q III, IV, V)
By
name
tie
Concurred By
name title
NOTE: 1. Instructions on reverse side.
2. Attach additional sheets as needed..
Date
Date)b— F

DUPLIN SWCD TECBMCAL REVIEW OF. SWINE
CERTMCATZONS PERFORMED BY NON MRCS OR DISTRICT
STAFF
NAME: 0 l� U
DATE RECEIVED: 4
SIZE AND TYPE OPERATION: 2�
SWINE INTEGRATOR:
TECHNICAL SPECIALIST:
All plan documents have been received in SWCD office.
f Waste plan appears adequate
Design was completed by MRCS '
Design was completed by PE and not reviewed by NRCS
Does the design package contain the following components and does each appear to be
addressed properly according to NRCS Technical Guide standards-?
Collection
Storage ,
Treatment
—� Operation -and Maintenance (Land Application)
WAS A FIELD REVIEW PERFORMED BY SWCD STAFF 10
WAS THIS REVIEW BASED SOLELY ON THE DOCUMENTS SUBMITTED BY THE
TECHNICAL SPECIALIST:
REVIEWER'S SIGNATURE:
DATE: _ /// f'�

1,/14/9
_1
Animal Waste Management Plan Certification
.(Please tvaa4w-vrint all information that does not require a sisznature)
General Information:
Name of Farm: B & O F�= #2 Facility No:
Owner's Name: 011ve ' 01ta Phone No: Q101293-73 m
Mailing Addxess• 1769 Ftad Fla NC
Farm Location: Fourteen Digit Hydrologic Unit:p3p3nve7e,be�p
Latitude and Longitude: _M� LQL jQIL / 770 59' 34" . . County: nmlin
Please attach a copy of a county road map with location identified and describe below
(Be 4 i. � ad names , directions, milepost etc.): Fjxm Kmxnv lle tale SR 1301, cp
riot rn l >� i3e F (SR 1300), go,2 mi_, t3D fern artrar7oe cn ricer
02gLrafion Dewri Zion:
Type of Swine No ofAnimals Type of Poultry No ofAnimals Type of Cattle No ofAnimals
1C Wean to Feeder 2600 Layer Dairy
_. Feeder to Finish — Pullets Beef
_ Farrow to Wean — —
Farrow to Feeder
Farrow to Finish Other Type of Livestock: Number of Animals:
Acreage Available for Application: 46.6 Required Acreage: _ _�_
Number of lagoons/Storage Ponds: 1 Total Capacity: �137.349 Cubic Feet (fts)
Are subsurface drains present on the farm: Q or - NO (please circle one)
Owner /Manager Agreement
I (we) verify that all the above- information is correct and will be updated upon changing: I (we)
understand the operation and maintenance procedures established in the approved animal waste
management plan for the farm named above and will implement these procedures. I (we) know that.
any expansion to the existing design capacity of the waste treatment and storage system or construction
of new facilities will require a new certification to be submitted to the.Division of Environmental
Management before the new animals are stocked. I (we) understand that there must be no discharge of
animal waste from the storage or application system to surface waters of the state either directly
through a man-made conveyance or from a storm event less severe than the 25-year, 24-hour storm
and there must not be run-off from the application of animal waste. I (we) understand that run-off of
pollutants from lounging and heavy use areas must be minimized using technical standards developed
by the Natural Resources Conservation Service. 'Me approved plan will be filed at the farm and at the
office of the local Soil and Water Conservation District_ .I (we) know that any modification must be
approved by a technical specialist and submitted to -the Soil and Water Conservation District prior to
implementation. A change in land ownership requires written notification to DEM or a new
certification (if the approved plan is changed) within 6o days'of a title transfer.
Name of land Owner:, QUVW CUt].W
Signature: 0..4.E • m 5,re D t42
e•
Name of ManagAr (if different from owner):
Signature:
AWC -- April 24, 1996

l
Technical Specialist Certification
L As a technical specialist designated by North Carolina Soil and Water Conservation Commission
pursuant to 15A NCAC GF .0005,1 certify that the animal waste management system for the farm
named above has an animal waste management plan that meets or.exceeds standards and specifications
of the Division of Environmental Management (DE O as specified in 15A NCAC 2H.0217 and the
USDA -Natural Resources Conservation Service (NRCS) and/or -the North Carolina Soil and Water
Conservation Commission pursuant to 15A NCAC 2H.0217 and 15A NCAC GF .0001-.0005. The
following elements are included in the plan as applicable. While each category designates a technical _
specialist who may sign each certification (SD, SI, WUP, RC,1), the technical specialist should only
certify parts for which they are technically competent.
II. Celi icadon of Design
A) Collection Stara a Treatment S stein ZK EASOI;
Check the appzoptrate box
❑ Existing facility without retrofit (SD or WUP) SSlQ,� 9
Storage volume is adequate for operation capacity; storage capability consisten
wi waste utilization requirements. SE Al
714985
New, expanded or retrofitted facility (SD)
Animal waste storage and treatment structures, such as but no limited to collects
systems, lagoons and ponds, have been designed to meet or exceed the minimum jjr
standards and specifications. iy, Eq�
Name of Technical Specialist (Please Print): J. Neal Ztxdkz�r
Affiliation:
Address (Agen ): Phone No.: 910 M -&M Dt. 4717
Signature:. Date:
B) Land Application Site (WUP)
The plan provides for minimum separations (buffers); adequate amount of land for
waste utilization; chosen crop is suitable for waste management; hydraulic and
nutrient loading rates.
Name of Technical
Affiliation: PlEk
Address (Agency):,
Signature: jLW-
List (Please Print) • M. Kevin wesbon
RI=
C) Runoff Controls from Exterior Lots
Check the appropriate box -
❑ Facility without exterior lots (SD or WUP or RC)
This facility does not contain any exterior lots.
❑ Facility with exterior lots (RC)
Methods to minimize the run off of pollutants from lounging and heavy use areas
have been designed in accordance with technical standards developed by MRCS.
Name of Technical Specialist (Please Print):
Affiliation:
Address (Agency): Phone No.:
Signature: Date:
AWC--April24, 1996
2

D) A lication and Handlin ui ment
check the appmpr&te box
❑ Exisfing facility with existing waste a lication ui ment (WUP or I) .
Animal waste application equipment specified in the plan has been either field
calibrated or evaluated in accordance with existing design charts and tables and is
able to apply waste as necessary to accommodate the waste management plan:
(existing application equipment can cover the area required by the plan at rates not
to exceed either the specified hydraulic or nutrient loading rates, a.schedule for
timing of applications has been established; required buffers can be maintained and
calibration and adjustment guidance are contained as part of the plan).
CJ" New or expanded facility, or existingf_ acMy without existing waste application
equipment (1)
Animal waste application equipment specified in the plan has been designed to
apply waste as necessary to accommodate the waste management plan; (proposed
application equipment can cover the area required by the plan at rates not to
exceed either the specified hydraulic or nutrient loading rates; a schedule for
timing of applications has been established; required buffers can be maintained;
cah-brations and adjustment guidance are contained as part of the plan).
" for ATr.4c#14t�6(T "
Name of Technical Specialist (Please Print): M_ BL=F,r3n West=
Affiliation:
Address (Agency).-ro EtR 759 Raee Bill W 2B458 Phone No.: ,(91039 Ddt. 4629
Signature: _ >,.t:. t<J�.L� Date:
III. Certrflcation oflnstaffatron
A) Collection Stora e T tment Installation
New, expanded or retrofitted facility (SI)
Animal waste storage and treatment structures, such as but no limited to
lagoons and ponds, have been installed in accordance with the approved plan to
meet or exceed the minimum standards and specifications.
For =sftggfaciblies withoutzvkofits, no certMation kn ry.
Name of Technical Specialist (Please Print): M. R-:v Wasbm
Affiliation: _MkftMk Family Fmm
Address (Agency): >~O Eac 759 l ee Hill, W 2645E Phone No.: (910,2M-&4 R EXt . 4629
Signature:. .mot • ��-�._ �.� Date: _ (—Z/-,
.1
AWC -- April 24, 1996

I
1
B) Land Application Site (WUP)
Check the appropriate brix
R__-The cropping system is in the place on all land as specified in the animal waste management plan.
© Conditional Approval: all. required land as specified in the plan is cleared for planting, the cropping
system as specified in the waste utilization plan has not been established and the owner has
committed to establish the vegetation as specified in the plan by
(month/day/year); the proposed cover crop is appropriate for compliance with the waste
utilization plan.
© Also check this box if appropriate
if the cropping system as specified in the plan can not be
established on newly cleared land within 30 days of this
certification, the owner has committed to establish an
interim crop for erosion control;
Name of Technical Specialist (Please Print): 1''1- YMn Wastrn
Affiliation: MMItH 1d1v Funs '
Address (Agency): lO R:D1 759 lie HL11, NC 22458 - - Phone No.: (910)2B9-6439 O t. 4629
Signature: '?07� -Date: F r �_
This following signature block is only to be used when the box for conditional approval in 111. B above
has been checked.
I (we) certify that I (we} have committed to established the cropping system as specified in my (our)
waste utilization plan, and if appropriate to establish the interim crop for erosion control, and will
submit to DEM a verification of completion from a Technical Specialist within 15 calendar days
following the date specified in the conditional certification.. 1 (we) realize that failure to submit this
verification is a violation of the waste management plan and will subject me (us) to an enforcement
action from DFAC
Name. of Land Owner:
Signature:
Name of Manager (If different from owner):
Signature:
Q Runoff Controls from Exterior Lots (RC)
Date:
Date:
Facilfty with exterior lots
Methods to minimize the'run off of pollutgnts from lounging and
heavy use areas have been installed as specified in the plan.
Forf=biies withoutextenorlots, no aeraacation isnecamry.
Name of Technical Specialist (Please Print):
Affiliation:
Address (Agency): Phone No.:
Signature: Date:
V AWC -- April 24, 1996
4

D) Application and Handling Equipment Installation (WUP or I)
Check the appropriate black
9' Animal waste application and handling equipment specified in the plan is on site and ready
for use; calibration and adjustment materials have been provided to the owners and are
contained as part of the plan.
❑ Animal waste application and handling equipment specified in the plan has not been
installed but the owner has proposed leasing or third party application and has provided a
signed contract; equipment specified in the contract agrees with the requirements of the
plan; required buffers can be maintained; calibration and adjustment guidance have been
provided to the owners and are contained as part of the plan.
❑ Conditional approval: Animal waste application and handling equipment specified in the
plan has been purchased and will be on site and installed by
(monlwday/year); there is adequate storage to
hold the waste until the equipment is installed and until the waste can be land applied in
accordance with the cropping system contained in the plan; and calibration and
adjustment guidance have been provided to the owners and are contained as part of the
Pam -
Name of Technical SSRgc (Please Print): M= YeAn We5bm
Affiliation:
Address (Agency):p0 BZK 759 Rae Hill IC 28458 Phone No.: 910 289-6439 Dt. 4629
�9_. ' ���. Date: G /i/y& t Signature: _- _
The following signature block is only to be used when the box for conditional approval in III D above
has been checked.
I (we) certify that I (we) have committed to purchase the animal waste application and handling
equipment as specified in my (our) waste management plan and will submit to DEM a verification of
delivery and installation from a Technical Specialist within 15 calendar days following the date specified
in the conditional certification. I (we) realize that failure to submit this certification is a violation of the
waste management plan and will subject me (us) to an enforcement action from DEM.
Name of Land Owner:
Signature: Date:
Name of Manager (if different from owner):
Signature: Date:
Please return the completed form to the Division of Environmental Management at the following
address:
Department of Environment, Health, and Natural Resources
Division of Environmental Management
Water Quality Section, Compliance Group
P. O. Box 29535.-
Raleigh, NC 27626•-0535
Please also remember to submit a copy of this form along with the complete Animal Waste Management
Plan to the local Soil and Water Conservation District Office and to keep a copy in your files with your
Animal Waste Management Plan.
AWC -- April 24, 1996

1
Animal Waste Management Plan Certification
ATTACHMENT A
to
FORM-AWC -- APRIL 24, 1996
General information:
Name of Farm: B & o FEMME #2- Facility No: -
Owner(s) Name: QUver O tlaw Phone No: [phone]
Mailing Address: 1769 Wanb Bdctg lead 4m--3a, W M458
IL Certification of Design
D.) Application and Handling Equipment
New or expanded facility; or existing facility without existing waste application
equipment (WUP or 1)
Animal waste application equipment specified in the plan has been either field
calibrated or evaluated in accordance with existing design charts and tables and is able
to apply waste as necessary to accommodate the waste management plan: (application
equipment can cover the area required by the plan at rates not- to exceed either the
specified hydraulic or nutrient loading rates, a schedule for timing of applications has
been established, required buffers can be maintained.and calibration and adjustment
guidance are contained as part of the plan).
Name of Technical Specialist (Please Print): M . Kin
Affiliation: Mz#V FardlY ROO
Address (AgenVO)
: ED Bic 759 � HLn, NC 28458
Phone No.: 39 EKt- 4629
Signature: ' jas Date: 6/i1,/9f
If the technical specialist chooses to use this Attachment to certify the design of a new
or expanded facility; or existing without existing waste application equipment; it must
be attached to the completed Animal Waste Management Certification Form (AWC-
April 24, 1996). The technical specialist must also Write in the words "See
Attachment" in Part 11. D. Of the Certification Form to notify the review agencies that
the Attachment has been used
This Attachment will not be acceptable past the effective date of the new NCRS
Technical Standards.
AWC - May s, 1996

�1
F AM I L Y F A R M S
June 7, 1996
Mr. Oliver Outlaw
1769 Wards Bridge Road
Warsaw, NC 28398
RE: Swine Farm Certification
Dear Mr. Outlaw:
Enclosed for your records is a copy of the final certification for your swine farm along
with a copy of your waste utilization plan. Please be aware that you must keep a copy
of t1tis certification and the waste utilization plan at the farm site.
Your farm. is subject to inspection by the Division of Environmental Management at
any time. Failure to have this information at the farm site or failure rb follow'the waste
J
Utilization plan puts you in violation of the State of North Carolina Non -Discharge
Regulations (19A-NCAC-2H, Section .0200, Subsection .0217) and makes you subject
to a Notice of Violation or fire from the Division of Environmental Management.
If you have any questions regarding this certification, please call me at
[phone] ext.-4629.
Sincerely:
M. Kevin Weston
Engineering Technician
cc: Toni King, Murphy Family Farms LNM Department
Dupan Soil -and Water Conservation
Post Office Box 759, Rose Hill, North Carolina 28458, [phone], FAX [phone]

1
ANIMAL WASTE UTILIZATION PLAN
Producer: OLIVER OUTLAW/JOHN BYRD
Location: 1769 WARDS BRIDGE RD
WARSAW NC 28398
Telephone: [phone]
Type Operation: Existing Wean to Feeder Swine
Number of Animals: 5200.00 pigs
(Design Capacity)
STORAGE STRUCTURE: Anaerobic Waste Treatment Lagoon
APPLICATION METHOD: Irrigation
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops
in the fields where the waste is to be applied..
This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply
more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall be applied -to land eroding at less than
5 tons per acre per year. Waste may be applied to land .
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on saturated soils, when it is raining,
or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed
under DWQ regulations.
Page: 1

ANIMAL WASTE UTILIZATION PLAN
5. wind conditions should also be considered to avoid drift and
downwind odor problems.
6. To maximize the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more than 30
days prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. If
you choose to change methods in the future, you need to revise this
plan. Nutrient levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from your
waste management facility. In some cases you may want to have plant
analysis made, which could allow additional waste to be applied.
Provisions shall be made for the -area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
This waste utilization plan, if carried out, meets the requirements
for compliance with 15A NCAC 2H .0217 adopted by the Environmental
Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
5200 pigs x .40 tons waste/pigs/year = 2080 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
5200 pigs x .96 lbs PAN/pigs/year = 4992 lbs. PAN/year
Applying the above amount of waste is a big job. You should plan
time and have appropriate equipment to apply the waste in a timely
manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
Page: 2

ANIMAL WASTE UTILIZATION PLAN.
TABLE 1: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
--------
APPLY
RESID.
APPLIC
METH
N
TIME
3120
8
AUB
C
75
73.75
20
16.9
1246.37
I
MAR-JUN
3120
-8
1WA
11
1100 f
116.9 11690
PR
3120
DSB
1-8
JAUll
I
118
172 1
116.9 11216.8
JUN-
SEPT 15
I
3120
9
FP
3.0
IFOA
I
I
1150 1
19.9 11485
SEP-APR
3120
FP
1-9
IFOA
li
13.0
1150 1
19.9 11485
SEP-APR
3120
10
C
75
73.75
JAUB
I
I
120
I
132.4 12389.5
MAR-JUN
3120
--1D
1
I
IWA
I
1100 1
132.4 13240
SEP-APR
3120
�10
DSB
2332.8I1.32.4
JAUll
118
172
JUN-
SEPT 15
3120
-�1DA
GOA
13.0
1771.25
IC
I
1125
1136.25120
IMAR-JUN
3120
10A
1
100
IWA
I
113 11300
SEP-APR
3120
�10A
GOA
DSB
I
13-5
J140
113
11820
JUN-
SEPT 15
3120
10A
GOA
TO
Q
0
113.0
END
Page:
3

ANIMAL WASTE UTILIZATION PLAN
TOTALI19976.7
- Indicates that this field is being overseeded (i.e.
interplanted) or winter annuals follow summer annuals.
NOTE: The applicator is cautioned that P and K may be over applied
while meeting the N requirements. In the future, regulations
may require farmers in some parts of North Carolina to have.a
nutrient management plan that addresses all nutrients. This
plan only addresses nitrogen.
Page: 4

ANIMAL WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
See required specification 2.)
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
-------
APPLY
RESID.
APPLIC
METH
N
TIME
END
TOTAL 10
Indicates that this field is.being overseeded (i.e. interplanted) or
winter annuals follow summer annuals.
** Acreage figures may exceed total acreage in fields due to
overseeding.
* lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and 2 above:
CROP CODE
CROP
UNITS
PER UNIT
C
CORN
BUSHELS
1.25
DSB
DOUBLE CROPPED SOYBEANS
BUSHELS
4
FP
TALL FESCUE -PASTURE
TONS
50
TO
TOBACCO
WA
WINTER ANNUALS (I.E. Small Grains, etc.)
AC
100
TOTALS FROM TABLES 1 AND 2
Page: 5

ANIMAL WASTE UTILIZATION PLAN
TABLE 1
TABLE 2
TOTAL
WETTABLE
—ACRES
59.2
W
59.2
*** BALANCE
LBS AW N USED
19976.72
0
19976.72
-14984.725
------------------
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.
Page: 6

ANIMAL WASTE UTILIZATION PLAN
*** This number must be less than or equal to 0 in order to fully
utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffers,'filter strips along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than
the.acres shown in the tables.
See attached map showing the fields to be used for the utilization of
animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land
application of'sludge at agronomic rates. The sludge will be nutrient
rich and will require precautionary measures to prevent over application
of nutrients or other elements. Your production facility will produce
approximately 395.2 pounds of plant available nitrogen per year in the
sludge.
If you remove the sludge every-5.years, you will have approximately 1976
pounds of PAN to utilize. Assuming you apply this PAN to hybrid-
bermudagrass hayland at the rate of 300 pounds of nitrogen per acre, you
will need 6.58666666667 acres of land. If you apply the sludge to corn at
the rate of 125 pounds of nitrogen per acre, you will need 15.808 acres
of land. Please be aware that these are only estimates of the PAN and
land needed. Actual requirements could vary by 25% depending on your
sludge waste analysis, soil types, realistic yields, and application
methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the
soil at the time of irrigation such that runoff or ponding occurs. This
rate is limited by initial soil moisture content, soil structure, soil
texture, water droplet size, and organic solids. The application amount
should not exceed the available water holding capacity of the soil at the
time of irrigation nor should the plant available nitrogen applied exceed
the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables 1 and 2. Failure to apply the recommended rates and
Page: 7

ANIMAL WASTE UTILIZATION PLAN
amounts of nitrogen'shown in the tables may make this plan invalid.
The following table is provided as.a guide for establishing application
rates and amounts.
I I
I
(Application
RatelApplic. Amount
Tract
I Field l
Soil Type
l Crop
I (in/hr)
l (inches)
3120
I I
110 I
AUB
I
l C
I
l .5
-
I
l *1
3120
I
l 8 l
AUB
I
l C
I
l .5
i *1
I
3120
1 9 l
FOA
I FP
l .50
l *1.0
3120
l --10 I
l WA
l .35
I *1
1
3120
I I
I --10 l
AUB
I
l DSB
I
I .5
l *1
3120
I
l --10A I
!
l WA
I
l .35
l *1
3120
I I
l -r10A l
GOA
I
I DSB
I
l .50
l *1.0
3120
l --10A I
GOA
l TO
3120
I I
l -10A I
GOA
I
I C
I
l .50
I
l *1.0
3120
I I
( -8 l
I
l WA
I
l .35
I
l *1
Page: 8

• ANIMAL WASTE UTILIZATION PLAN
-1-1
3120
1 -8
I AL
1
I DSB
1 1.
I .5 f
3120
I --9
I FDA
I FP
1 .50
*1
*1.0
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations, the application amount shown cannot
be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180.00 days of temporary storage and
the temporary storage must be removed on the average of once every
6.00 months. In no instance should the volume of the waste be stored
in your structure be within the 25 year 24 hour storm storage or one
foot of freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply the
correct rates to the acres shown in Tables 1 and 2. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may
make this plan invalid.
Call your technical specialist after you receive the waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate prior to applying the waste.
NARRATIVE OF OPERATION
THIS PLAN IS WRITTEN BASED ON A TWO YEAR CROP ROTATION. FIELD NUMBER 10A WILL
HAVE A TWO YEAR'ROTATION THAT INCLUDES TOBACCO. THERE WILL BE NO PUMPING WHEN
TOBACCO IS PLANTED ON THIS FIELD. THERE WILL BE EITHER CORN OR SOYBEANS
PLANTED DURING THE OTHER CROP YEAR. TABLE ONE ON PAGE THREE GIVES THE NUTRIENT
BUDGET TO BE USED FOR PUMPING ON EACH FIELD. THE WINTER ANNUAL(WA) IS A SMALL
GRAIN CROP TO BE PLANTED BEHIND CORN. THIS CROP MAY BE EITHER GRAZED OR
HARVESTED.
Page: 9

-1
WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner'of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
5. Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or -
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during
rainfall events, or when.the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be considered.
Page: 10

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the -crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to
wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be.applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly into water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
the site.
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as -necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and
other.woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 11

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
18. If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste.
storage ponds.
22. Waste shall be tested within 50 days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when these
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be
maintained for five ( 5 ) years.
23. Dead animals will be disposed of in a manner that meets North
Carolina regulations.
Page: 12

ANIMAL WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: B&O #102
Owner/Manager Agreement
I (we) understand and will follow and implement the'specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new
facilities will require a new certification.to be submitted to the
North Carolina Division of Water Quality (NCDWQ) before the new
animals are stocked. I (we) also understand that there must be no
discharge of animal waste from this system to surface waters of the
state from a storm event less severe than the 25-year, 24-hour
storm. The approved plan will be filed on -site at the farm office
and at the office of the local Soil and Water Conservation District
and will be available for review by NCDWQ upon request.
Name of Facility Owner: OLIVER OUTLAW/JOHN BYRD
(Please print)
Signature: Date: .1 — Cj
Name of Manager(I£ different from owner):
Signature: Date:
Name of Person Preparing Plan: (please print)BILLY W. HOUSTON
Affiliation:DUPLIN SOIL AND WATER CONSERVATION DISTRICT
Phone No. 910-296-2120
Address (Agency): PO BOX 277
RENANSVILLE NC 28349
Signature: Date:
Page: 13

.{. yy.,�1wsJ, w����1�4-` }Jr•t� :1:..- `i� a rtl:.
+ r' 'b=•r •+-r.+:Y Try[ _�'r . r�:
It-
1 w.w�...-,�"{'�L�.�...'� ws"L�•S�S:..y(�.1.�-aT�aa,.- � ��.�.t- 1 � .M + -.�.
- '�.1 -v,Y �A .�7„„y :f Y� J 'h�,r1, E r <' .�L• l.�J... rl y I'i
s=: v T r�l iYy f '� !"rycw� r•�' .{� � � � •'.i r J - � ' y •� � -
_ � ��'rl.. � J,LL ••�! "w a•c�f fr ♦wY ,��a w[ 1 c
• Y1
+ � — l�ti�l � s' ti�j''•r 1.,, r �.•, i•-ti�r4 �..,��tJ _t,. .,'. . ,: ,.•' _ .•.
'� yap .d• � 1. r•' .'r: •t. J'�.5,.... . t,' _.:; - ': ',:
C:T era, - r�. _ti.. ;,�. � 'T [!' �.::t.-'1�` � «i'.�• *� .; t. �
i r '�`s'�• .r �!: i•.C'i "r �a � -:-3'��•'r.!i'..��.a. v. I�'• �.r-•T ti' , r , ti �'
�� r o'�"i+l^`?[[i�. t �wii;i;`- Y.'.rr, +t.tr fix„• � - , r '
F �i 5"�ksl• p" I a„�. �6�"t;�] iix,, .;'�x"!''�-}'�.:.•f i •`,
`r. a<<.�" . �h• _ a t•,�'ta ^•..yr .•'[�+1� r ia.'R'• 'r•..^ a�+,. tea• t ,.r . � �: c. + •^�
7�y3� h� li ,ate ur t. 2 T, Ct•r a' •d'�.W ��r�-..�t•,1:5- '�!�K•-t�.1' *_. -r: �,y�; �:='?�r�:',:':. `,-;.' '1 �''.' •''.
'�� : _ 4•• _ �•,i•� ,..�.��..�...' r:,�r_,_ai= : ._"��`r-:lam

.- ',._ � ` - -�•f..' - ,��-,[ ,fir: - -, � �- -,1 �' �� -�
--'..'•�„_\�(��- lam•.-r+3 "�K..: .. _ _ _ - :,. .r :Li.> .,{Y ''•. .. -rr`-. �.
� � -_ ,. •: 1 � - Al ' • • ,� - f
- .. v:6�4..+, .. rei" �, h cL F r/ rr Yc ., (? [ tt•
to
t
t. r
Y
r� ear rj-i�t �F�tlr ti-t)�� q. - t

Ak
el"
" §-i' 'I-

INSECT CONTROL- CHECKLIST FOR ANIMAL OPERATIONS
Source Cause BMP's to Minimize Odor Site Specific Practices
(Liquid Systems)
Flush Gutters Accumulation of solids ( ush system is designed and operated
sufficiently to remove accumulated
soiids from gutters as designed.
(4-R`emove bridging of accumutated solids at
discharge
Lagoons and Pits Crusted Solids t_)yaintain lagoons, settling basins and
pits where pest breeding is apparent to
minimize the crusting of solids to a depth
of no more than 6-8 inches over more than
30% of surface.
Excessive Vegetative Decaying vegetation HIMaintain vegetative control along banks of
Growth lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along water's edge on impoundment's perimeter.
{Dry Systems}
Feeders Feed Spillage ( } Design, operate and maintain feed systems (e.g.,
bunkers and troughs) to minimize the accumulation
of decaying wastage.
() Clean up spillage on a routine basis (e.g. 7-10 day -
interval during summer; 15-30 day interval during winter).
Feed Storage Accumulations of feed residues ( ) Reduce moisture accumulation within and around
immediate perimeter of feed storage areas by
insuring drainage away from site and/or providing
adequate containment (e.g.. covered bin for
brewer's grain and similar high moisture grain
products)-
{ } Inspect for and remove or break up accumulated
solids in filter strips around feed storage as needed.
Animal holding Areas Accumulations of animal wastes I) Eliminate low area that trap moisture along fences
and feed wastage and other locations where waste accumulates and
and disturbance by animals is minimal.
{ } Maintain fence rows and filter strips around animal
holding areas to minimize accumulations of wastes
(i.e. inspect for and remove or break up accumulated
solids as needed).
AMIC--November 11, 1996

Dry Manure Handling Accumulations of animal wastes (} Remove spillage on a routine basis (e.g. 7-10 day
Systems interval during summer; 15-30 days interval during
winter) where manure is loaded for land application
or disposal-
{ I Provide for adequate drainage around manure stockpiles.
(} Inspect for and remove or break up accumulated wastes
in filter stripes around stockpiles and manure handling
areas as needed.
The issues checked ( ) pertain to this operation. The landowner/integrator agrees to use sound judgment in applying
insect control measures as practical.
I certify the aforementioned insect control Best Management Practices have been reviewed with me.
(Landowner Signvure)/
O [ 1V rf ✓�aw T-'ar..+
(Fatm, Name)
31- 30
'(Facility Number)
For more information contact the Cooperative Extension Service, Department of Entomology, Box 7613, North Carolina State university, Raleigh, NC
27695-7613.
AMC —November 11. 1S96

M
MORTALITY MANAGEMENT METHODS
(check which methods) are being implemented)
( ) Burial three feet beneath the surface of the ground within 24 hours
after knowledge of the death. The burial be at least 300 feet from
any flowing steam or public body of water. -
Rendering at a rendering plant licensed under G. S. 106-168.7
( ) Complete incineration
( } In the case of dead poultry only, placing in a disposal pit of a size and
design approved by the Department of Agriculture.
( } Any method which in the professional opinion of the State
Veterinarian would make possible the salvage of part of a dead
animal's value without endangering human or animal health. (Written
approval of the State Veterinarian must be attached)

SWINE FARM WASTE MANAGEMENT ODOR CONTROL CHECKLIST
Source
Cause
BMP's to Minimize Odor Site Specific Practices
Farmstead
Swine production
ff9egetative or wooded buffers;
040commended best management
practices;
/
(� 6,00d judgment and common sense
Animal body surfaces
Dirty manure -covered animals
(y'Dry, floors
Floor surfaces
Wet manure -covered floors
(- Slotted floors-
0"Waterers located over slotted floors;
( ) Feeders at high end of solid floors;
(-KScrape manure buildup from floors;
(7 Underfloor ventilation for drying
Manure collection pits
Urine
(- -1' requent manure removal by flush,pit
recharge,or scrape
Parital micorbial decomposition
(rUnderfloor ventilation
Ventilation exhaust fans Volatile gases; (4-fan maintenance;
Dust (4-'6ficient air movement
Indoor surfaces Dust ( ashdown between groups of animals
(} Feed additives;
(} Feeder covers;
(} Feed delivery downspout extenders to
feeder covers
Flush tanks Agitation of recycled lagoon
O Flush tank covers
liquid whiles tanks are filling
(} Extend fill lines to near bottom of
tanks with anti -siphon vents
Flush alleys Agitation during wastewater
(TTnderfloor flush with underfloor
conveyanance
ventilation
Pit recharge points Agitation of recycled lagoon (1 Extend rechard lines to near bottom of
liquid while pits are filling pits with anti -siphon vents
Lift stations Agitation during sump tank filling (} Sump tank covers
and drawdown
Outside drain collection Agitation during wastewater (} Box covers
or junction boxes conveyance
End of drainpipes at lagoon Agitation during wastewater
Extend discharge point of pipes
underneath lagoon liquid level
Lagoon surfaces Volatile gas emissions
{ roper lagoon liquid capacity
Biological mixing
Wcorrect lagoon startup procedures
Agitation
(-r Minimum surface area -to -volume ratio
( 41inimum agitation when pumping
(} Mechanical aeration
() Proven biological additives
Irrigation sprinkler nozzles High pressure agitation
( Irrigate on dry days with little or no wind
Wind draft
tTywmum recommended operation pressure
PI/Pump intake near lagoon liquid surface
( ) Pump from second -stage lagoon
AMOC—November 11, 1996

Storage tank or basin
surface
Partial microbial decomposition
Mixing while filling
Agitation when emptying
() Bottom or midlevel loading
() Tank covers
{) Basin surface mats of solids
{ 1 Proven biological additives or oxidants
Settling basin surface Partial micobia) decomposition { J Extend drainpipe outlets underneath liquid
Mixing while filling level
Agitation when emptying { Remove settled solids regularly
Manure, slurry or sludge Agitation when spreading
"-f;oif injection of slurrylstudges
spreader outlets Volatile gas emissions
( ) Wash residual manure from spreader after use
( I Proven biological additives or oxidants
Uncovered manure, slurry Volatile gas emissions while drying
( oil infection of slurry/sludges
or sludge on field surfaces
W,,eoil incorporation within 48 hours
(Spread in thin uniform layers for rapid drying
() Proven biological additives or oxidants
Dead animals Carcass decomposition (.),Proper disposition of carcasses
Dead animal disposal Carcass decomposition () Complete covering of carcasses in burial pits
pits [ ] Proper location/construction of disposal pits
Incinerators Incomplete combustion { I Secondary stack burners
Standing water around Improper drainage (4, rade and landscape such that water drains
facilities Microbial decomposition of away from facilities
organic matter
Manure tracked onto public Poorly maintained access roads { arm access road maintenance
roads from farm access
Additional Information: Available From:
Swine Manure Management; 0200 Rule/BMP Packet
NCSU-County Extension Center
Swine Production Farm Potential Odor Sources and Remedies, EBAE Fact Sheet
NCSU-BAE
Swine Production Facility Manure Management: Pit Recharge --Lagoon Treatment; EBAE 128-88
NCSU-BAE
Swine Production Facility Manure Management: Underfloor Ruse --Lagoon Treatment; EBAE 129-88
NCSU-BAE
Lagoon Desig and Management for Livestock Manure Treatment and Storage; EBAE 103-83
NCSU-BAE
Calibration of Manure and Wastewater Application Equipment; EBAE Fact Sheet
NCSU-BAE
Controlling Odors from Swine Buildings; PIN-33
NCSU-Swint Extension
Environmental Assuranc Program: NPPC Manual
NC Pork -Produces Assoc
Options for Managing Odor; a report from the Swine Odor Task Force
NCSU Agri Communications
Nuisance Concerns in Animal Manure Management Odors and Flies; PRO107, 1995 Conference Proceedings Florida Cooperative Extension
The issues checked (-- pertain to this operation. The landownerrntegrator agrees to use sound judgment in applying
odor control measures as practical.
I certify the aforementioned odor control Best Managment Practices have been reviewed with me.
'r,00., -
AMOC--November 11, 1996

EMEk,;ENCY ACTION PLA..
PHONE NUMBERS
DIVISION OF WATER QUALITY (DWQ) [phone]
EMERGENCY MANAGEMNET SERVICES (EMS) [phone]
SOIL AND WATER CONSERVATION DISTRICT (SWCD) [phone]
NATURAL RESOURCES CONSERVATION SERVICE (NRCS) [phone]
COOPERATIVE EXTERSION SERVICE (CES) [phone]
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing or running off site. You should not wait until wastes reach surface waters
or leave 'you property to consider that you have a problem. You should make every
effort to ensure that this does not happen. This plan should be posted in an accessible
location for all employees at the facility. The following are some action items you should
take.
1. Stop the release of wastes. Depending on the situation, this may ore may not be
possible. Suggested responses to some possible problems are listed belwo.
A. Lagoon overflow -possible solutions are:
a. Add "soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B. Runoff from waste application field -actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that cause the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
D. Leakage from -flush systems, houses, solid separators -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
E. Leakage from base or sidewallof lagoon. Often this is seepage as opposed
to flowing leaks -possible action:
a. Dig a small sump or ditch from the embankment to catch all
seepage, put in a submersible pump, and pump back to lagoon.
b. if holes are caused by burrowing animals, trap or remove animals and fill
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon
bottom as soon as possible.
1

2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what duration?
c. Any damage notes, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a'future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours call your DWQ regional office; Phone - -. After
hours, emergency number: 919-733-3942. Your phone call should include: your
name, facility number, telephone number, the details -of the incident from item 2
above, the exact location of the facility, the location or direction of movement of
the spill, weather and wind conditions. The corrective measures that have been
under taken, and the seriousness of the sitution.
b. If spill leaves property or enters surface waters, call local EMS phone number.
c. Instruct EMS to contact local Helath Department.
d. Contact CEs, phone number - , local SWCD office phone number - -, and local
NRCS office for advice/technical assistance phone number - -.
4. if none of the above works call 911 or the Sheriff's Department and explain you
problem to them and ask the person to contact the proper agencies for you.
5. Contact the contractor of your choice to begin repair or problem to minimize off -
site damage.
a. Contractors Name: Wedlj ro��ie�l Co•u�n.��-�b�
b. Contractors Address: _ IcL L ►„er k; ll RA . TV r �&,i . he 2k34 1
c. Contractors Phone:
6. Contact the technical specialist who certified the lagoon (NRCS, Consulting
Engineer, etc.)
a. Name: _� A '1 Fact"r - -
b. Phone: -- 91D-._°f.���
7. Implement procedures as advised by DWQ and technical assistance agencies to
rectify the damage, repair the system, and reassess the waste managment plan to
keep problems with release of wastes from happening again.
2

�•,:_�,,r,�ti7 r'' �� � ,_, :rt�'f��Yt,J•'�, .•:rt;��l
i )'1 �•, '��� w ry f�••zv�j,'-rw'�
' •-L`t.✓'•f_I.1 _- �I•:tkt.x ..:- - -.i �1�. •''�Tx/,�:""r'J �. :�i
- - _ - - i r 1 - :>�_'; :d'rr _i ','_':) "` -t 4. r�, r '' 4~'•'a:s~Z<--- _'� t' !"
� � ..'"""��e• a, t fr,T �,� p'.. f,_ � f i � 't -a r,l. ` 71, t t
_ � _ _ � r „' �'�•=�4.JiY,f::', �' ,' -_ _• - r � i � -`� 1 � ► vet
t - r � -'1r� _ 's' cr'•-+r r �` ��ir iZ�- X `��,'� "'F
IN
Al
dO
_ Y -�S. > ✓�:�;Sy�. �`r���,����_ I���, � � �. !/� .� � - a� Win.
r' > _.. - -. _ .. --, r _r•t :,•jam �5 �Ss .' # �rR"�r.J :! ti,.�^ 1;, n-Iti •-'ti � ry''
f/ - L._ _ %T:i w� rJ` -d,F � �l. ,ter �# �• s`�l—���' ��� P
72
1 - - t :'� z �- '�•t�i�_�-' �•� � ,Jc r �..�tl. �, :i'� L..- �_ �.>�+r•�f'a.►.4.:a
-
�� r
� � )� 1��ri7j� •��,t �y_� `�: � tryt4 1. _•� +c._• '-*•' - r : ~ Y f R.�-
�� _`, t •[3�:�•�Y i� ei::me��^ CY y L'' �, 1; -�'•+ i ; p_- � t' � � _

i wItz - . . - ; - . : - ' , -
ILI
* VRI-
A�i
RN!
7!D
C'V•e".
't--L
. ..... . . . . . ." . ......

7.4
dcm,r

/ Z1i1119S
F A M I L Y F A R M$
December 1 1, 1995
Mr. Mike Sugg
District Conservationist
USDA - Natural Resource Conservation Service
P. O. Box 277
Kenansville, NC 28349
RE: B & O Farm #2 - 2600 Nursery
Dear Mr. Sugg:
Enclosed for your review is the completed Animal Waste Management Plan for the
above referenced swine farm. Specific items included in this package are as follows:
- Location Map
- ASCS Tract Map
- Soils Investigation Report
- Lagoon Design Spreadsheet
- Operation & Maintenance Plan for Lagoon
- Construction Specifications for Lagoon
- Site Seeding Requirements
- Earthwork Calculations
- Site Plan with Construction Details
It is my understanding that the Wastilization Plan for this farm will be developed
for the grower by_ym office.
PIease contact me at [phone], ext. 4629 if you have any questions concerning
this package.
Post Office Box 759, Rose Hill, North Carolina 28458, [phone], FAX [phone]

-,1
Sincerely,
M. Kevin Weston
Engineering Technician
MKW.tbh
Enclosures
cc: File
Oliver Outlaw, (complete package)
Robert Henderson, Murphy Family Farms Construction Dept. (site plan only)
Dave Roland, Murphy Family Farms Transportation Dept_. (site plan
only)

Mm
"I to
fro

,•rf �_•i Syr i"'rya,ry'1'. r }v, .1 fir`+4, rL�.I� �+ �LJ 1 �a IV FL' •.t
11� " I.
�rrt S 4 j4�,f
5 �+a. r-1'r+•1} +� 1 } ~'ry I s�+ti;�y,r3 r-4 + 1}ll
'? /..�vi'�rL:•.'r ...w7;l:.e'�-k: :':� .'n,�::w..• :�,'~'��•'r 1'. ..:i �.
_ .'y r � :+"':►fsvtii;ra.:.+: .J: J 1 JJ'y.4 J S 4 .�,;� r.i1:�+'+ i kie�¢s•Yr:�'Jd',�_.:,•
';�.!iyr J' '! iJ-t ..:i•<s }J w� E '$�a+t I r = J 1 '!��'n%y„ �"
.:'•1•L ;,� i ��- `�� H 751 1 ii-tr '' � rJ) ��i1
�.,'` •`. t V �/• y+1,T { J. 4 �'1�5: s 1 is
m
JJ�r y'
� 14 is r
�
>" �➢ �
t� 5
yy
lw;
4" 1
i, Y 1 ,,�jj'i•,y�,�
'V y�j M i 1t�4 '+`Ciwiilh► •� 'C � t h + ♦. ' Wf
JT}'•
Y;1~.,'�`r� j •}f t�bTr.' ' I[' 's Cti �, ,`'fie'^.'„ s .��oy a ,e
r
• L •! T`fl if �, �'t i ya a r J ter#
L ' ,i�r s N• y rV r , � � - t 5.
,l �.yAi:� ;�Yt ,(�� •;� }..ir 1��'!•y- �o-l_ q i �•.,' +5d} 1 -5� �Yi
Ft�i� i; fJr li�➢'� � rr 1 1v' it �y'+V it ',N l;1r ;• i A - x` gs h t, .'y �
VV �
tt w
N [I.. I f� :if k l +rlalt 4 IM f 4 , ys p tt r r l,y '2 V
1 r'Sf
1'•��r sl `'f �r�� � f�, };ip�'+�1 �I�r3 } � I{c s ,� r-. i -
i
,, 4'1 �; fr S`,4�-.,..>,•.( }' }i,�.,�� ir�'Sr�t1 ', � , E r _ \ ,�
'ctt���,�{�f:.,77
�r
R
, y. �r� J lt! � :i�''l5 l ; �d li �ryr'"f���ur.5•i 31 `s'� I 3 ! r � 5
+ 1t 'a.�r �,�; �5�' ' � r��di+�•y � 4s�s �r . r-,fin. n 7.V � 1
�., t I i'3"!r k�}'1f 9.a P '� e . T• k � ��� •�1}.�� bi 7 ldY r t 4 1 -
��
'�
w.i��Iti
}�'
gj
yfillYWC� �V�P�rr j"'a��•� Y1.��.✓ S e,y➢a ,e }!L �b� r � �f r'
}r 7� I. J vWT �43�. IY ' i .,�:1 'S I�}r� � i�'' �'•^�11 �'° r. r r s c .i ,,?- 'J+ ?

LAGOON SITE'SOILSANVESTIGATION-'
PROJECT:
COUNTY:
FIELD INVESTIGATION BY: KW .7- DATE:
SITE SKETCH
rz
J 77
�_ BORING
rtbTf T~WCi
BORING NUMBER AND PROFILE-
7y
Av
41117-M;10-1�2:1 Zll.l-,.,;iF-,• -
SIGNATURE: ING 1,,GAMPUNG METHOD; 0"006; �,
. *�- - -
-e . - . ;

,erator:OLIVER OUTLAW County: DUPLIN
.stance to nearest residence (other than owner):
AVERAGE LIVE WEIGHT (ALW)
Date: 12/07/95
1500.0 feet
0
sows
(farrow to
finish)
x
1417
lbs. =
0
lbs
0
sows
(farrow to
feeder)
x
522
lbs. -
0
lbs
0
head
(finishing
only)
x
135
lbs. -
0
lbs
0
sows
(farrow to
wean)
x
433
lbs. =
0
lbs
2600
head
(wean to feeder)
x
30
lbs. -
78000
lbs
Describe other :
0
Total Average Live Weight = 78000 lbs
MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 78000 lbs. ALW x Treatment Volume(CF)/lb. ALW
Treatment Volume(CF)/lb. ALW = 1 CF/lb. ALW
Volume = 78000 cubic feet
STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0.0 cubic feet
TOTAL DESIGNED VOLUME
Inside top length (feet) ------- 7------------- 154.0
Inside top width (feet)---------------------- 154.0
Top of dike elevation (feet)----------------- 105.2
Bottom of lagoon elevation (feet)------------ 95.2
Freeboard (feet) -------------------------- - - 1.0
Side slopes (inside lagoon)------------------ 3.0 : 1
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH
3.0 3.0 3.0 3.0 148.0 146.0 9.0
AREA OF TOP
LENGTH * WIDTH =
148.0 148.0
AREA OF BOTTOM
LENGTH * WIDTH =
94.0 94.0
21904 (AREA OF TOP)
8836 (AREA OF BOTTOM)
AREA OF MIDSECTION
LENGTH * WIDTH * 4
121.0 121.0 58564 (AREA OF MIDSECTION * 4)
CU. FT. _ [AREA TOP + (4*AREA MIDSECTION) + AREA BOTTOM] * DEPTH/6
21904.0 58564.0 8836.0 1.5
Total Designed Volume Available = 133956 CU. FT.

TEKPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
154.0 154.0 23716.0 square feet
Buildings (roof and lot water)
0.0 square feet Describe this area.
TOTAL DA 23716.0 square feet
Design temporary storage period to be 180 days.
�. Volume of waste produced
Feces & urine production in gal./day per 135 lb. ALW 1.37
Volume = 78000 lbs. ALW/135 lbs. ALW f 1.37 gal/day 180 days
Volume = 142480 gals. or 19048.1 cubic feet
3. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume = 0.0 gallons/day +
Volume = 0.0 cubic feet
180 days storage/7.48 gallons
per CF
Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall = 7.0 inches
Volume = 7.0 in —DA / 12 inches per foot
Volume = 13834.3 cubic feet

). Volume of 25 year - 24 hour storm
Volume = 7.5 inches /"12 inches per foot - DA
Volume = 14822.5 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A.
19048
cubic
feet
5B.
0
cubic
feet
5C.
13834
cubic
feet
5D.
14823
cubic
feet
TOTAL 47705 cubic feet
SUMMARY
Temporary storage period====================>
180
days
Rainfall in excess of evaporation===========>
7.0
inches
25 year - 24 hour rainfall===_______________>
7.5
inches
Freeboard==--========================--=====>
1.0
feet
Side slopes_________________________________>
3.0
. 1
Inside top length===========================>
154.0
feet
Inside top width==---=================---===>
154.0
feet
Top of dike elevation=======================>
105.2
feet
Bottom of lagoon elevation==================>
95.2
feet
Total required volume_______________________>
125705
cu. ft.
Actual design volume========--==--==========>
133956
cu. ft.
Seasonal high watertable elevation (SHWT)===>
.96.7
feet
Stop pumping elev.__________________________>
101.5
feet «
Must be > or = to the SHWT elev.==========>
96.7
feet
Must be > or = to min. req. treatment el. =>
101.2
feet
Required minimum treatment volume===========>
78000
cu. ft.
Volume at stop pumping elevation============>
81053
cu. ft.
Start pumping elev._________________________>
103.3
feet +�
Must be at bottom of freeboard S 25 yr. rainfall
Actual volume less 25 yr.- 24 hr. rainfall==>
119134
cu. ft.
Volume at start pumping elevation===========>
114953
cu. ft.
Required volume to be pumped================>
32882
cu. ft. +►
Actual volume planned to be pumped==========>
33900
cu. ft.
Min. thickness of soil liner when required==>
1.5
feet
DESIGNED BY: APPROVED BY :
DATE: DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
COMMENTS•

OPERATION ANT) MAINTENANCE FLAN SHEET 1 OF 2
This lagoon is designed for waste treatment (permanent storage) and
180 days of temporary storage. The time required for the planned
fluid level (permanent and temporary storage) to be reached may vary
due to site conditions, weather, flushing operations, and the amount
of fresh water added to the system.
The designed temporary storage consists of 180 days storage fo•r:
(1) waste from animals and (2) excess rainfall after evaporation. Also
included is storage for the 25 year - 24 hour storm for the location.
The volume of waste generated from a given nu"mbe-r of animals will be
fairly constant throughout the year and from year to year, but excess
rainfall will vary from year to year. The 25 year rainfall will not
be a factor to consider in an annual pumping cycle, but this storage
volume must always be available.
A maximum elevation is determined in each design to begin
pumping and this' is usually the outlet invert of pipe(s) from
building(s). if the outlet pipe is not installed at the elevation to
begin pumping, a permanent marker must be installed at this elevation
to indicate when pumping should begin. An elevation must be established_
to stop pumping to maintain lagoon treatment depth.
Pumping can be started or stopped at any time between these two
elevations for operating convenience as site conditions permit, such as
weather, soils, crop, and equipment in order to apply waste without
runoff or leaching.
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set,
center pivot, gums, and traveling gin irrigation. Care should be
taken when applying waste to prevent damage to crops.
The following items are to be carried out:
1. It is strongly -recommended that the treatment lagoon be pre-
char_ged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times. When 'precharging is comple'e,
flush buildings with -recycled lagoon liquid. Fresh water should not
be used for flushing after initial filling.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testini3 of waste (see attachment)
before land application.
3. Begin temporary storage pump -out of the lagoon when fluid level
reaches the elevation 103.3 as marked by permanent marker. Stop pump -
out when the fluid level reaches elevation 101.5 This temporary
storage, less 25 yr- 24 h•r storm, contains 32882 cubic feet or
245961 gallons.

SHEET 2 OF 2
. 4. The recommended maximum . mount to apply per irrigatAn is
one (1) inch and the recommended maximum application -rate is 0.3
inch per hour. Refer to the waste utilization plan for further details.
5. Keep vegetation an the embankment and arenas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted fTom the lagoon to stable
outlets.
8. Keep a minimum of 25 feet of grass vegetated buffer around
waste utilization fields adjacent to perennial streams. Waste will
not be applied in open ditches. Do not pump within 200 feet of a
residence or within 100 feet of a well. Waste shall be applied in a
manner not to reach other property and public right-of-ways.
9. The Olean Water Act -of 1977 prohibits the discharge of.
pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.

SHEET 1 OF 2
SPECIFICATIONS FOR CONbrRUCTION OF WASTE "TREATMENT LAGOONS
FOUNDATION PREPARATION. -----------------------
-
The foundation area of the lagoon embankment and building pad shall be
cleared of trees, logs, stumps, roots, brush, boulders,sod and rubbish.
Satisfactory disposition will be made of all debris. The topsoil from
the lagoon and pad area should be stripped and stockpiled for use on
the dik.e and pad areas. After stripping, the foundation area of the
lagoon embankment and building pad shall be thoroughly loosened prior
to placing the first lift of fill material to get a good bond.
EXCAVATION AND EARTHFILL PLACEMENT:
-----------------------------------
The completed excavation and earthfill shall conform to the lines,
grades, and elevations shown on the plans. Earthfill material shall
be free of material such as sod, roots, frozen soil, stones over
G inches in diameter, and other objectionable material. To the extent
they are suitable, excavated materials can be used as fill. The fill
shall be brought Ltp in approximately horizontal layers not to exceed 9
inches in thickness when loose and prior to compaction. Each layer
will be compacted by complete coverage with the rattling and sp-reading
equipment or standard tamping -roller or other equivalent method.
Compaction will. be considered adequate when fill material is observed
to consolidate to the point that settlement is not 'readily detectible..
NOTE THE SPECIAL REQUIREMENTS FOR PLACEMENT OF LINERS IN THE LINER
SECTION OF THIS SPECIFICATION. The embankment of -the .lagoon shall be
installed using the more impervious materials from the required
excavations. Construction of fill heights shall include S percent for
settlement. Dikes over 15 feet in height and with an impoundment
capacity of 10 acre-feet or more fall under the jurisdiction of the NC
Dam Safety Law. The height is defined as the difference in elevation
from the constructed height to the downstream toe of the dike.
Precautions shall be taken during construction to prevent excessive
erosion and sedimentation.
LINER: THE MINIMUM REQUIRED THICKNESS SHALL BE 1.5 ft.
NOTE.- LINERS (PARTIAL OR FULL) ARE REQUIRED WHEN THE ATTACHED SOILS
INVESTIGATION REPORT SO INDICATES OR WHEN UNSUITABLE MATERIAL IS
ENCOUNTERED DURING CONSTRUCTION. A TYPICAL CROSS SECTION OF THE LINER
IS INCLUDED IN THE DESIGN WHEN LINERS ARE REQUIRED BY THE SOILS REPORT.
When areas of unsuitable material are encountered, they will be over --
excavated below finish grade to the specified depth as measured
perpendicular to the finish grade. The foundation shall be backfilled
as specified to grade with a SCS approved material (ie - CL,SC,CH).
REFER TO THE SOILS INVESTIGATION INFORMATION IN THE PLANS FOR SPECIAL
CONSIDERATIONS.

SHEET O OF G
.Soil liner material shall cu.ae' from an approved borrow .,rea. The
minimum water content of the 'liner material shall be optimum moisture
content which relates to that moisture content when the soil is kneaded
in the hand it will form a ball which does not readily separate. Water
shall be added to borrow as necessary 'to insure proper moisture content
during placement of the liner.- The moisture content of the liner
material shall not be less than optimum water content during placement.
The maximum water content relates to the soil material being too wet
for efficient use of hauling equipment and proper compaction. proper
compaction of the liner includes placement in 9 inch lifts and
compacted to at least 90 percent of the maximum ASTM D699 Dry Unit
Weight of the liner material. When smooth or. -hard, the previous lift
shall he scarified and moistened as needed before placement of the next
lift.
The single most important factor affecting the overall compacted perme-
ability of a clay liner, other than the type of clay used for the
liner, is the efficient construction processing of the compacted liner.
The sequence of equipment use and the •roLkting of equipment in an estal:)--
lished pattern helps assure uniforAii.ty in the whole placement and
compaction process. For most clay soils, a tamping or sheepsfoot
roller is the. preferable type of compaction equipment.
The soil liner shall be protected from the discharge of waste outlet
pipes. This can be clone by using some type of energy dissipator('rocks)
or using flexible outlets an waste pipes.
Alternatives to soil linters are synthetic liners and bentonite sealant.
When these are specified, additional construction specifications are
included with this Construction Specification.
CUTOFF TRENCH:
--------------
A cutoff trench shall be constructed under the embankment area when
shown on a typical cross section in the plans. The final depth of the
cutoff trench shall be determined by observation of the foundation
materials.
VEGETATION:
------------
All exposed embankment and other bare constructed areas shall be seeded
to the planned type of vegetation as soon as possible after construc-
tion according to the seeding specifications. Topsoil should be placed
on areas of the dike and pad to be seeded. Temporary seeding or mulch
Shall be used if the recommended permanent vegetation is out of season
dates for seeding. Permanent vegetation should be established as soon
as possible during the next period of approved seeding dates.
REMOVAL OF EXISTING TILE DRAINS
-------------------------------
When tile drains are encountered, the tile will be removed to a minimum
of 10 feet beyond the outside toe of slope of the dike. The tile
trench shall be backfilled and compacted with goad material such as
.SC, CL, or CH.

SEEDING SPECIFICATIONS
AREA TO BE SEEDED: 2.5 ACRES
USE THE SEED MIXTURE INDICATED AS FOLLOWS:
750.0 LBS. FESCUE GRASS AT 60 LBSIACRE .
(BEST SUITED ON CLAYEY OR WET SOIL CONDITIONS)
SEEDING DATES: SEPTEMBER-1 TO NOVEMBER 30
FEBRUARY 1 TO MARCH 30
75.0 LBS. RYE GRAIN AT 30 LBS./ACRE (NURSERY FOR FESCUE)
150.0 LBS_ 'PENSACOLA' BAHIA GRASS AT 50 LBS./ACRE
(SEE FOOTNOTE NO. 1)
SEEDING DATES. MARCH 15 TO DUNE 15
20.0 LBS_ HULLED COMMON BERMUDA GRASS AT 8 LBSIACRE
(SUITED FOR MOST SOIL CONDITIONS)
SEEDING DATES: APRIL 1 TO JULY 31
25.0 LBS. UNHULLED COMMON BERMUDA GRASS AT 10 LBS.,ACRE
SEEDING DATES: JANUARY 1 TO MARCH 30
100.0 LBS. RYE GRASS AT 40 LBS.IACRE (CEMPORARY VEGETATION)
SEEDING DATES: DECEMBER 1 TO MARCH 30
:-A
APPLY THE rOLLOWiNG:
25M.0 LBS. OF 10-10-10 FERTILIZER (1000 LBSJACRE)
5.0 TONS OF DOLOMITIC LIME (2 TONSIACRE)
250.0 BALES OF ShIALL GRAIN STRAIN (100 R3ALESlACRE)
ALL SURFACE DRAINS SHOULD BE INSTALLED PRIOR TO SEEDING. SHAPE
ALL DISTURBEDAREA IMMEDIATELY AFTER EARTH MOVING IS COMPLETED.
APPLY LIME AND FEFMLlZER THEN DISK TO PREPARE A 3 TO 4 INCH
SMOOTH SEEDBED. APPLY SEEDAND FIRM SEEDBED WfTH A CULTIPACKER
OR SIMILAR EQUIPMENT. APPLY MULCH AND SECURE WITH A MULCH
ANCHORING TOOL OR NETTING.
1_ PENSACOLA BAHIAGRASS IS SLOWER TO ESTABLISH THAN COMMON
BERMUDA GRASS. WHEN USING BAHIA, fT IS RECOMMENDED THAT 8
LBSJACRE OF COMMON BERMUDA BE INCLUDED TO PROVIDE COVER
UNTIL R3MUkGRASS IS ESTARUSHED.

• � '��`� . .'ram ��;: fit.• •.'� ��; -�•� ':=.''"'«-t_„i y���
41.
Tw,• 3 _ rr t — i �fy: sirt"K
".{•: r�4 :_ --aate�
.ram y . _- :i•', �.1. �=. `- ��.v,}, �',r
' � _ �� �� '-_ya��t s 3 y�:F �i��/'/-� t. •fir t� _ i
.J' � ���1t-,?��` .._# .r 4 •;:fir .��
k C f I/
�!I r
I. ,x � �'*ir+I'� - �- �L : �: 0'.�5.. 7�.Y' - ��tir� i '~-•y:�_,�'.c:T? asryi = i;
- -� /'• - pit:. _ Y ..._ _�t.i i
_k
aFi`ktti
r — _ :ate.. �l's!: - �%'� �ti- s-" �i�'�. -•
id
Ail
Mir

� f
- , '.-� 1 F\� -� 't"t ��.., � t v'GT �' :• l ;:r`Sf:4.. L.; s `.'.'�" - �+yly
L t -' ��'-� � � �` :gib •' • , �:�.�•... � ,
_ • � 'ts'r, • � j< ; �.,:'-... r�. �.<a : c_ ' - tic:`i•`'1�t:fe-� e ' .. 'r, .: Sr"' C.='is•.ti.«?'�''t • S
- : �L-:, 'L: .''�'�' ,kr� :i:,.d ti4' ; - r�R�l,:'r'; •h, y ••J�- \F � �i-, �•�:. �� 3. .f, �.•f :. .
• r, i r >; •.,.: K._ ?( 1 - it '`"', r•� ",;*�,.. ? tf°;G�.`,r�"�,.,y,.
,, -. r - _r F.Y - ~• �'r - 4 : ',� LLy 1 y! 1. •�- .++, .yr-a. !�- � � T! � : w-,�., ��r., 1� ,... �w �,
3 r _ 11 L - _' , t r. 1y�lr^L' ^� '' is s at �l^4� w n. 'ti.•�� r�Fw .+fl �k 'N ga
�,_W
_ � � • • ti ::.�� `Jv ti''''1' �'.y '� • }��:.�r `' .4.t~'3. a ^F"+► � �l� �-`~ a. -,�, � t?L7Cp .�Ip!'
r.- •t• � ' r K I .tlti'" Y�� �/� :�� }I,ww r�..=-s.+`'ti�.S, �'I I . � 1,. - .�r�•tJ. - i,�A,,, f` 1+;,�t+s-� 1
_• � ..tV -*, ..-S ��� WL. rS -S'� 1, aYt w..a 1.,.1,;1�ra '��,, �4� �` S ...Y:.��''
_ '.y �. - i'--t' _:.': •;.��: ��'F:."fir "r. �,, �• v�''S r''�k w ':�. .{ =1RXC `9 �'+1'v f .1;'{
� ff
'•'G. ;! _F r, r :.� ``'��.�' `5_ �r' �;�- fl-T��.n� ,,a- -.r f ` I,.TIr�: F,�_� ,, J�e!'�5 'r,
�� L Jt ',•i. •�j" •• • X ] � „yam ^i 1 t� Y
�
• �. -� a -`-yam F�1 �qr 1' `
t s• - r -
-777
SST, �`� � ` � `i r 4 �y ,�F'•` "•r ry`t 1 'i•� 1 ` ti� *: `'�',F,•S ..� �I �x(
'�, fit` k' „Y '_ i _ �y- � 1 �1�� ..• 'rT f !�.
,1 r,�..y �4 tr ,. .y' •y ' . �c n R: `�`�:: ;:T.Y * �� �'Y � '.r..'y �� r 'r?',:
�1� `�}lam - - ��1'v�l•!j- `_ ir���f `3 '7t �..i!�!i•?�.. _::�. _ _
�.1s.,23'
`.-
� �r
,s r,.

State of North Carolina
Department of Environm
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governo
Bill Holman, Secretary
Kerr T. Stevens, Director
OLIVER OUTLAW
B&O FARM
1769 WARDS BRIDGE RD
WARSAW NC 28398
Dear Oliver Outlaw:
APR 112000
April 7, 2000
4 • •
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Certificate of Coverage No. AWS310305
B&O Farm
Swine Waste Collection, Treatment,
Storage and Application System
Duplin County
In accordance with your application received on March 24, 2000, we are forwarding this Certificate of
Coverage (COC) issued to Oliver Outlaw, authorizing the operation of the subject animal waste
collection, treatment, storage and land application system in accordance with General Permit
AW6100000. This approval shall consist of the operation of this system including, but not limited to,
the management of animal waste from the B&O Farm, located in Duplin County, with an animal
capacity of no greater than 5200 Wean to Feeder and the application to land as specified in the Certified
Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This request
shall be made within 30 days of notification by the Division.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]B
An Equal opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Certificate of Coverage AWS310305
B&O Farm -- — _—_--
Page 2
This COC is not automatically transferable. A name/ownership change application must be submitted to
the DWQ prior to a name change or change in ownership. ---
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual non -discharge permit by contacting the engineer listed below for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
The subject farm is located in the Wilmington Regional Office. The Regional Office Water Quality Staff
may be reached at [phone]. If you need additional -information concerning this COC or the
General Permit, please contact Susan Cauley at [phone] ext_ 546.
Sincerely,
`-�A
Kerr T. Stevens
cc: (Certificate of Coverage only for all cc's)
Duplin County Health Department
Wilmington Regional Office, Water Quality Section
Duplin County Soil and Water Conservation District
Permit File
NDPU Files

�r r
Operator: _____,___ ==a=====_ _______=a ae=a====> pliver..Outlaw
County:== Duplin-
Date:==== ########
Dist.to nearest residence (other than owner): ft.
sows (farrow to finish) :=== =Qa=============_>
sows (farrow to fee eder):==_
head (finishing only):===__
sows (farrow to wean):===-s
head (wean to feeder):====_
Ave. Live sleight for other operations(lbs.)=>
Storage volume for sludge accum. (cu. ft.):=>
Treatment Volume (min. 1 cu. ft./lb.)=======>
25 Year - 24 Hour Rainfall
Rainfall in excess of evaporation (in.)=====>
Drainage area of buildings & lots (sq. ft.).>
Volume of wash water (gallons/day)====_=====>
Temporary storage period (days)=============>
Freeboard
Side slopes (inside lagoon):===a============>
Inside top length
Inside top width
Top of dike elevation
Bottom of lagoon elevation (ft.):===a ====>
Seasonal high water table(SHWT) elev.(ft.):=>
Total required volume:===== ________> 121945
Actual design volume:=== 150554
Stop pumping el.(> or = to 38.0 ft.SHWT)>
(> or = to 34.5 ft.Min.)
Required minimum treatment volume: 78000
Volume at stop pumping elevation: 98998
Start pumping elev.:==================___=>
Volume at start pumping elevation: 137457
Actual volume less 25yr-24hr rain: 137677
NOTE: Verify that temp. storage is adequate:
Req. volume to be pumped:====> 31067
Actual volume to be pumped:==> 38459
cu
cu
0
2600
1.0
7.5
7.0
180
1.0
2.5 : 1
136:0
151.5
-42.5
28.5
38.0
ft.
ft.
38.5 ft.
cu. ft.
cu. ft.
40.8' ft.
cu. ft.
cu. ft.
cu. ft.
cu. ft.

it
U
Operatore(JLIVER OUTLAW County. DUPL-IN Date: 09/22/93
Distal -ICE' tQ neCXr OSt residence (Other- than owner-) -. 1000.00 feet nr09
1. STEADY STAVE LIVE WF_ I rl-1T
0
stows
(farrow to
finish)
x 1417
lbs. —
0
lbs
0
Rows
(farrow to
feeder)
:; 52P
lbs,
0
lbsi
0
hC'ad
(finli5hing
curtly)
x 135
lbs. =
0
lbs
0
sows
(farrow to
wean)
x 433
lbs. =
0
lbw,
P600
hears
(wean to feeder)
x 30
lbs. -
79000
lbs
TOTAL STEODY STATE LIVE WEIGHT (SSLW) = 78000 Ibs
r. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Vo I rime, -- 78000 lbs. SSL.W x Treatment Vo 1 ume (CF) / 1 b . Sal_W
Treatment Volume(C:F)/1b. SSLW= 76000 CF/lb. SSLW
VoImfic? 7fJ000 cubic 'feet
3. STORAGE VOLUME FOR SLUDGE: ACCUMULATION �
Volume - 0.00 cubic feet
+. TOTAL. DEESIGN VOLUME T
Inside top length 150.00 -feet ; Inside top width 125.00 feet
Tap (if clike at elevation 46.00 'feet
Freeboard 1.:30 feet ; Side slopes 2.50 : 1 (Inside lagoon)
Total drasign lagoon Liquid level at elevation 44.70 feet
nottom of lagoon elevation 32.50 feet
Seasonal (sigh water table elevation 4b—.-E .'•f c
'total design volume using prismoidal formula
S S/END1 S;.3/END2 SS/SIDE1 55/SIDE 2 LENGTH WIDTH DEPTH
2.5 2.5 2.5 2.50 143.5 110.s 12.20
AREA O1= TOP
L U10TH * WIDTH
143.5 11H.1i
AREA OF 33OTTOM
LEWC3141 * WIDTH =_
132 .5 57.5
17005 (AREA OF TOP)
4744 (AREA OF BOTTOM)
AREA OF M I D SUCT I ON
LENGTH .K W I TH * 4
113.0 88.0 . 39776 (AREA OF MIDSECTION * 4)
CU . FT. (. ARF_A TOP + (4#AREA MIDSECTION) + AREA BOTTOM] DEPTH/6
17004. 8 39776. 00 4743.7 2.(
VOLUME:. 017 LAGOON AT TOTAL DESIGN LIQUID LEVEL 125100 CU. FT.

5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top or dike)
Length * Width ==
190.0 125.0 18750.0 square feet
Buildings (roof and lot water)
Length * Width
0.00 0.00 0.0 square 'feet
TOTAL DA 18750.0 square feet
Design temporary storage period to be
180 days.
i
5A. Volume- of waste produced
Approximate daily production of manure in
CF/LB SbLW 0.00136
Vo IuffiC = 70000 Lbs . SSLW * CF of Waste/Lb
. /Day * 180 days
VC, 1ume 19094 cubic feet
5B . Volume of waah water
E
i
This is the amount of fresh water used for washing floors or volume
Of tress► Water used for a flush system.
Flush systems that recrirculat
the lagoon water z�re accounted for in 5A.
Volume = 0.0 gallons/day
180 days storage/7.48 gallons
per CF
Volume i1.0 Cubic 'feet
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds
evaporation by largest amount i
i
180 clays excess rainfall
7.0 inches
Volume - 7.0 in * nA / 12 inches per
I
foot '
Volume = 1093'7.5 cubic: feet

5D. Volume of 25 year -- 24 hour storm
Volume == 7.5 inches / 12 inches per foot ae DA
Volumes - 11718.0 cubic feet
TOTAL REQUIRED TEMPORARY STORABE
5A. 19094 cubic -feet
5B. 0 cubic: Feet
5C. 1093B ciAbic -foot
5D. 11719 cubic: feet
TOTAL 41751 cubic feet
6. SUMMARY
Total required volume 119751 cubic feet
Total design volume avail. 125100 cubic feet
Min. req. treatment volume plus sludge accumulation 78000 cubic: ff
At elev. 41.60 feet ; Volume is 78431 cubic 'feet (end pumping)
TOtctl desiyti_1 vDlume less 25yr-24hr storm is 113301 cubic feet
At elev. 42.91). feel; ; Volume 19 111911 cubic feet (start pumping
341-04
Seal ,,onal high water table elevation 4X57"d'Cr, fec3t
7. DESIGNED BY: `v "--APPROVED BY :f�
DATE: DATE: � d "$ • 9�
SCS DOES NOT CERTIFY
NEWT=: SF.1= ATTACHED WASTE UTILIZATION PLAN THAT EXCAVATION AND
FILL VOLUMES ARE
cor1M NT :-------.__ .-----•--•-�.---- ._�__._r. , CORRECT
- t

Peo 0 2--
Operator: _________ __________________________>,Oliver,outlaw
County:— __________..__=--=>-DuuuyypYYiyyiii
Date:========aaa== ______�__ ===========_____=>
#######g
Dist.to nearest residence (other than owner):
ft.
sows (farrow to finish):___
sows (farrow to fee eder):--- ___
head (finishing only):====_ __--_=_== W==-==__>
0
sows (farrow to wean):_____
head (wean to feeder):====_ _________ ________>
2600
Ave. Live Weight for other operations(lbs.)=>
Storage volume for sludge accum. (cu. ft.):=>
Treatment Volume (min. 1 cu. ft./lb.)===__-=>
17.0
25 Year - 24 Hour Rainfall (in.)============>
7.5
Rainfall in excess of evaporation (in.)=====>
7.0
Drainage area of buildings & lots (sq. ft.)=>
Volume of wash water (gallons/day)==========>
Temporary storage period (days)========a= --- >
184
Freeboard(ft.):____________________________>
i.0
Side slopes (inside lagoon):======___=======>
3.0, 1
Inside top length (ft.):==__________________>
154.0
Inside top width
154.0
Top of dike elevation (ft.):________________>
105..2
Bottom of lagoon elevation (ft.):=R= =====>
95.2
Seasonal high water tabie(SHWT) elev.(ft.):=>
Total required volume:=======a=====> 125705
cu. ft.
Actual design volume:====== _-__-___> 133956
cu. ft.
Stop pumping el.(> or Q to 0.0 ft.SHWT)>
101.5 ft.
(> or = to 101.2 ft.Min.)
Required minimum treatment volume: 78000
cu. ft.
Volume at stop pumping elevation: 81053
cu. ft.
Start pumping
ib3.3 ft.
Volume at start pumping elevation: 114953
cu. ft.
Actual volume less 25yr-24hr rain: 119134
cu. ft.
NOTE: Verify that temp. storage is adequate:
Req. volume to be pumped:====> 32882
cu. ft.
Actual volume to be pumped:==> 33900
cu. ft.

001 ator ! OLIVER OUTLAW county: DUPLI N Date. 12/07/95
. tanc a 1_0 nearest residence (other than otrner) : 1500.0 feet
AVERAGE LIVE WEIGHT (ALW)
CA
saws
(:farrow -to
:fsnish)
x
1417
lbs. =
0
1b-x
*
sous
(farrow to
:feeder)
x
522
lbs.
0
lbs
O
head
(finishing
only)
x
135
lbs.
0
lbs
0
sows
(ta:r:row, to
wean)
X
430
lbs. -
0
lbs
2600
head
(wean to feeder)
x
30
lbs. -
78000
lbs
Describe other ;
0
Total. Average Live Weight = 78000 lbs
KINIMUR REQUIRED TREATHEHT VOLURE OF LAGOON
Volume = 78000 lbs. ALW a Treatme-int Volupie(CF)/.Lb. ALW
Treatment Volume(GF)/lb. ALW = I CF/lb. ALW
Volume-* = 78000 cubic Ieet
STORAGE VOLUME FOR SLUDGE ACCUMULATION
n
Volume = 0.0 cubic feet
TOTAL DFSIGRED VOLUKE
Inside 'cap length (feet) ---------------------
154.0
inside top width (feet)------------------------
154.0.
Top of dike elevation (feet)-------------------
105.2
Bottom of lagoon elevation (feet)--------------
95.2
Freeboard (feet)--------------------------------
1.0
-aide slopes (inside lagoon) --------
3.0 : 1
Total design volume using prismoidal formula
SS/ErlD1 SS/END2 SS/SIDEI SS/SIDE2 LENGTH
WIDTH DEPTH
3.0 3.0 3.0 3.0 148.0
148.0 9.0
AREA OF TOP
LENGTH = WIDTH
148.0 148.0
AREA OF BOTTOM
LENGTH * WXOTH
94.0 0 94.0
219034 ( AREA OF TOP)
8836 ( AREA OF BOTTOM)
AREA OF NIOSECTION
LENGTH WXDTH 4 4
121.9) 121.0 58564 (AREA OF fl X DSECTX OH 4 4 )
CU. FT. _ [AREA TOP - (4•kAREA ?JIIDSEcriom) -+- AREA 130TTOIJ l DEPTH/6
21904.0 58564.0 8836.0 1.5
Total Designed Volume Available = 133956 CU. FT.

T 213PORAR'1 STORAGE RiaS)i.ItRED
DRAINAGE AREA:
Lagoon ( top of dike)
Length c Width
154.0 154.0 2371G.0 square feet
Buildings (roof and _lo•L• water)
0.0 square feet Describe this area.
TOTAL DA 2371G.0 square creel.
Design -temporary storage period to be 180 clays.
s. Volume of waste produced
Feces & urine production in gal./day per 1:35 lb. ALW 1.37
Volume = 78000 lbs. ALW/135 lbs. ALW * 1.37 gal/day 180 days
Volume = 142480 gals. or 19048.1 cubic feet
i. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume = 0.0 gallons/clay 180 days storage/7.48 gallons
per GF
Volume = +0.0 ,-cubic .feat
�. Volume of rain all in excess 01 evaporation
Use period of ti we when rainfall exceede evaporation by largest amount.
180 clays excess rai_ngall = 7.0 inches
Volume = 7.0 in ;- DA / 12 inches per foot
Volume = 13834.3 cubic: fe:.et

). Vizjlume of 25 year -- 24 hour starm
Volume = 7.5 inches / 12 inches per foot x• DA
Volume = 14622.5 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A.
19048
cubic
feet
5B.
0
cubic
feet
5C.
. 13834
cubic
Xeet
5D.
14823
cubic
feet
T13TAL 47705 cubic feet
SUMMARY
Temporary storage 180 clays
Rainfall in excess of )% Q1 inches
25 year - 24 hour 145 incises
1.0 Feet
Side slopes=-====---__- _-_=.__W=W= __-- 3.0 . 1
Inside top 154.0 feet
Inside top 154.0 feet
Top of dike 105.2 feet
Bottom of lagoon 95.2 :feet
Total required volume______________-____=__=s .125705 cu. It. +
Actual design 133956 cu. ft.
Seasonal high watertable elevation (SHWT)===1 96.7 feet
Stop pumping 101.5 feet �
Must be y or = to the SHWT elev. ________==> 96.7 Meet
Must be `.• or = to min. reg. treatment el. =:- 101.2 feet
ReguIred 7n;lY,i*4m treatment 78000 cu. ft.
Volume at stop pumping rlcvai:ian=---=---___-- BA053 cu. ft.
�itart putnxFxng ��3ev.=------------------------- .1O3. 3 feet
Must be at bottom of freeboard & 25 yr. rainfall
Actual volume fleas 25 yr. - 24 hr. , ainfall==> 119134 cu. ft.
Volume at start pumping elevation=====__-__ 114953 cu. it.
Required volume to be 32362 cu. ft.
Actual volume planned to be pumped=====_ =_-=, 33900 cu. It.
i1_i.n. thickness of soil liner when :required==> A.5 _feet
DESIGNED BY: APPROVED BY :
JUALAN
DATE.: DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
CtMMbENTS :

SWINE FARM WASTE MANAGEMENT ODOR CONTROL CHECKLIST
Source Cause
BMP's to Minimize Odor Site Specific Practices
Farmstead Swino production
( eactativa or wooded buffers;
(+J ecommended boat management
✓practices;
(-7 uood judgment and common sons*
Animal body surfaces Dirty manure -covered Animals
{115ry floors
Floor surfaces Wot manure-eavered floors
0" lottod floors;
(-1 sterors located over slotted floors;
( ) Feeders at high end of solid floors;
(-1'�erapa manure buildup from floors; '
ff Underfloor ventilation for'drying
Manure collection pits Urine {_1'Frequent manure removal by flush,ph
rocharge,or scrape
Parital micorbial decomposition ( underfloor ventilation
Ventilation exhaust fens Volatile gases; (-j'Fan maintenance;
Dust (�fficient air movement
Indoor surfaces bust (eshdown between groups of animals
{ } Feed additives;
( } Feeder covers;
( Food delivery downspout extenders to
foodor covers
Flush tanks Agitation of recycled lagoon
( } Flush tank covers
liquid whiles tanks are filling
I 1 Extend fill lines to near bottom of
tanks with anti -siphon vents
Flush alleys Agitation during wastetater
(44nderfloor flush with underfloor
convayanance
ventilation
Pit recharge points Agitation of recycled lagoon I ) Extend rachard lines to near bottom of
liquid while pits are filling pits with anti-siplion vents
Lift stations Agitation during sump tank filling (1 sump tank covers
and drawdown
Outside drain collection Agitation during wastewater (} Box covers
or junction boxes conveyance
End of drainpipes at lagoon Agitation during wastewater
t4 Extend discharge point of pipes
underneath lagoon liquid level
Lagoon surfaces Volatile gas emissions
( roper lagoon liquid capacity
Biological mixing
J-' arrect lagoon startup procedures
Agitation
(yMMnimum surface area -to -volume ratio
(+4nimum agitation when pumping
(} Mechanical aeration
(} Proven biological additives
Irrigation sprinkler nozzles High pressure agitation
( Irrigate on dry days with little or no wind
Wind draft
(9inimum recommended operation pressure
Pump intake near lagoon liquid surface
( 1 Pump from second -stage lagoon
AMOC--November 11. 1996

Storage tank of basin Partial microbial decomposition ( ) Bottom or midlevel loading
surface Mixing while filling ( ) Tank covers
Agitation when emptying ( 1 Basin surface mats of solids
( ) Proven biological additives or oxidants
Settling basin surface Partial mlcobial decomposition { ) Extend drainpipe outlets underneath liquid
fWxing while filling level
Agitation when emptying O Remove Bottled solids regularly
Manure, slurry or sludge Agitation when spreading "oil injection of slurry/sludges
spreader outlets volatile gas emissions O Wash residual manure from spreader after use
O Proven biological additives or oxidants
Uncovered manure, slurry Volatile gas omissions while drying I Wail infection of slurry/sludges
or sludge on field surfaces incorporation within 48 hours
(4-'6pread in thin uniform layers for rapid drying
( I Proven biological additives or oxidants
Dead animals Carcass decomposition (4-Proper disposition of carcasses
Dead animal disposal Carcass decomposition O Complole covering of carcasses in burial pits
pits f) Proper location/construction of disposal pits
Incinerators Incomplete combustion I) Secondary stack burners
Standing water around Improper drainage (grade and landscape such that water diains
facilities Microbial decomposition of away from facilities
organic matter
Manure tracked onto public Poorly maintained access roads (}'Farm access road maintenance
roads from farm access
Additional Information: Available From:
Swine Manure Management; 0200 RuleIBMP Packet
NCSU-County Extension Center
Swine Production Farm Potential Odor Sources and Remedies, EBAE Fact Sheet
NCSU-BAE
Swine Production Facility Manure Management: Pit Recharge --Lagoon Treatment; EBAE 128-88
NCSU-BAE
Swino Production Facility Manure Management: Underfloor Fluso--Lagoon Treatment; EBAE 129-88
NCSU-BAE
Lagoon Dosig and Management for Livestock Manure Treatment and Storage; EBAE 103-83
NCSU-BAE
Calibration of Manure and Wastewater Application Equipment; EBAE Fact Sheet
NCSU-BAE
Controlling Odors from Swine Buildings; P114-33
NCSU-Swine Extension
Environmental Assuranc Program: NPPC Manual
NC Pork Produces Assoc
Options for Managing Odor; a report from the Swine Odor Task Force
NCSU Agri Communications
Nuisance Concerns in Animal Manure Management: Odors and Rios; PRO107, 1995 Conference Proceedings Florida Cooperative Extension
The Issues checked (pertain to this operation. The landowner/integrator agrees to use sound judgment in applying
odor control measures as practical.
I certify the aforementioned odor control Best Managment Practices have been reviewed with me.
AMOC--November 11, 1996

INSECT CONTROL CHECKLIST FOR ANIMAL OPERATIONS
Source Cause RMP's to Minimize Odor Site Specific Practices
(Liquid Systems)
Flush Gutters Accumulation of solids ('crush system is designed and operated
sufficiently to remove accumulated
soilds from gutters as designed.
f-�-nmovo bridging of accumulated solids at
dischirge
Lagoons and Pits Crusted Solids Qjldintain lagoons, settling basins and
pits where pest brooding is apparent to
minimize the crusting of solids to a depth
of no more than 6-8 inches over more than
30% of surface.
Excessive Vegetative Decaying vegetation FrMaintain vegetative control along banks of
Growth lagoons and other impoundments to prevent
accumulation of decaying vonelative matter
along water's edge on impoundment's perimater.
{Dry Systems}
Feeders Feed Spillage { I Design, operate and maintain feed systems fe.g.,
bunkers and troughs) to minimize the accumulation
of decaying wastage.
(1 Clean up spillage on a routine basis (e.g. 7.10 day
interval during summer, 15-30 day interval during winter).
Feed Storage Accumulations of feed residues { 1 Reduce moisture accumulation within and around
immediate perimeter of feed storage areas by
insuring drainage away from site and/or providing
adequate containment (e.g., covered bin (or
brewers griin and similar high moisture grain
products).
(1 Inspect for and remove or break up accumulated
solids in filter strips around feed storage as needed.
Animal Folding Areas - Accumulations of animal wastes : (j Eliminate low area that trap moisture along fences
and feed wastage and other locations where waste accumulates and
and disturbance by animals is minimal.
{ } Maintain fence rows and filter strips around animal
holding areas to minimize accumulations of wastes
(i.e. inspect for and remove or break up accumulated
solids as needed).
AMIC--November 11, 1996

Dry Manure Handling Accumulations of animal vrastes I I Remove spillage on a routine basis ta.g. 7-10 day
Systems interval during summer; 15.30 days interval during
winter} where manure is loaded for land application
or disposal.
I 1 Provide for adequate drainage around manure stockpiles.
(} Inspect for and remove or break up hccumulated wastes
in filter stripes around stockpiles and manure handling
areas as needed.
The issues checked pertain to this operation. The landownerlintegrator agrees to use sound judgment in applying
insect control measures as practical.
I certify the aforementioned insect control Best Management Practices have been reviewed with me.
x &��
•sGG
(Landowner Sign re)
L2 Far rt'�L 1 Ol tvt., �✓ (Ipw- Far,+
(Fa m Name)
a 31�,30
(Facility Number)
For more information contact the Cooperative Extension service, Department of Entomology, Box 7613. North Carolina state University, Raleigh. NC
27695-7613.
AMIC—November 11, 1996

MORTALITY MANAGEMENT METHODS
(check which method(s) are being implemented)
( } Burial three feet beneath the surface of the ground within 24 hours
after knowledge of the death. The burial be at least 300 feet from
any flowing steam or public body of water.
( -l"" Rendering at a rendering plant licensed under G. S. 106-168.7
( ) Complete incineration
( } In the case of dead poultry only, placing in a disposal pit of a size and
design approved by the Department of Agriculture.
{ } Any method which in the professional opinion of the State
Veterinarian would make possible the salvage of part of a dead
animal's value without endangering human or animal health. (Written
approval of the State Veterinarian must be attached)

EMERj ENCY ACTION PLA.
PHONE NUMBERS
DIVISION OF WATER QUALITY (DWQ) [phone]
EMERGENCY MANAGEMNET SERVICES (EMS) [phone]
SOIL AND WATER CONSERVATION DISTRICT (SWCD) [phone]
NATURAL RESOURCES CONSERVATION SERVICE (NRCS) [phone]
COOPERATIVE EXTERSION SERVICE (CES) [phone]
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing or running off site. You should not wait until wastes reach surface waters
or leave you property to consider that you have a problem. You should make every
effort to ensure that this does not happen. This plan should be posted in an accessible
location for all employees at the facility. The following are some action items you should
take.
1. Stop the release of wastes. Depending on the situation, this may ore may not be
possible. Suggested responses to some possible problems are listed belwo.
A. Lagoon overflow -possible solutions are:
a. Add'soil to berm to increase elevation of dam.
b. Rump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B. Runoff from waste application field -actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that cause the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
D. Leakage from flush systems, houses, solid separators -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
E. Leakage from base or sidewallof lagoon. Often this is seepage as opposed
to flowing leaks -possible action:
a. Dig a small stamp or ditch from the embankment to catch all
seepage, put in a submersible pump, and pump back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon
bottom as soon as possible.

2.
3.
4.
5.
1.1
Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what duration?
c. Any damage notes, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a'future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off the property)?
h. How much reached surface waters?
Contact appropriate agencies.
a. During normal business hours call your DWQ regional office; Rhone - -. After
hours, emergency number: 919-733-3942. Your phone call should include: your
name, facility number, telephone number, the details of the incident from item 2
above, the exact location of the facility, the location or direction of movement of
the spill, weather and wind conditions% The corrective measures that have been
under taken, and the seriousness of the sitution.
b. If spill leaves property or enters surface waters, call local EMS phone number.
c. Instruct EMS to contact local Helath Department.
d. Contact CEs, phone number - , local SWCD office phone number - -, and local
MRCS office for advice/technical assistance phone number - -.
If none of the above works call 911 or the Sheriff's Department and explain you
problem to them and ask the person to contact the proper agencies for you.
Contact the contractor of your choice to begin repair or problem to minimize off -
site damage.
a.
b.
C.
Contractors Name:
Contractors Address:
Contractors Phone: n in Ste•- "PS , ---
Contact the technical specialist who certified the lagoon (NRCS, Consulting
Engineer, etc.)
a. Name:
b. Rhone:
7. Implement procedures as advised by DWQ and technical assistance agencies to
rectify the damage, repair the system, and reassess the waste managment plan to
keep problems with release of wastes from happening again.
2

i
f
_-ease raze= tea .C==gIezed fo== to tie t;r'_a= - e= r'_ a? , �� at
the add ess C= the =averse soda 0=11a fo ==.
Adc; es s :
Cqurt ••,�.��
rat- location: Latitude and Longitude :ao D_3/-Zi` LUf.� (required) . Also,
please attach: a copy of a county road map with location identified_
'Tripe of operation (swine, layer, dairy, etc.)
Cesic = capacity (numher of animals) : !S3(� C:
Average site of operation' (12 month populatior. avg_) : �G OC)
Average acreage needed for land application of waste (acres)i0 -�
Tecn=icaZ s eclallar cas•zwficatiaa
As a technical specialist designated by the North Carolina Soil and Water
Conservation Commission pursuant to 15A NCAC 6=--0005, _ certify that the new or
expanded animal waste management system as installed for the =a-s na;,ed alove
has an animal waste management plan that meets the design, cons tzuction,
operation and maintenance standards and specifications .of the Division or
onviron=ental Management and the USDA -Soil Conservation Service and/or the North
Carolina Soil and water Conservation Commission pursuant to 15A NCAC 2E.0217 and
HA NCAC 6_ . 0001-.0005. The following O ements and their corresponding minimum
criteria-hnue_been verified by me or other designated technical specialists and
are included in the plan as applicable: minimum separations (buffers) ; liners or
equivalent for lagoons or waste storage ponds; waste storage capacity; adequate
quantity and amount of land for waste utilization (or use of third party) ; access
or ownership of proper waste application equipment; schedule for timing of
applications; application rates; loading rates; and the control of the discharge
of pollutants from stormwater runoff events less severe than the 2S-year, 24-hour
storm.
*lame of k'ec'..=: al Specialist (Please Przntj l �2 •
Affiliation- / -
Address (Agee •D. O 4 Phone No, 11,16
Signature: / ; Dade:
Cwze=/�anas-,ar �eamaat '••,�,�• . �c'<' = '
I (we) understand the operation and maihi.t PznceoceoVes established in the
approved animal waste management plan for £aoy pin ty+'a.bove and will implement
these procedures. I (we) know that any adI8Q;Q QY:pansion to the existing
design capacity of the wastA" treatment and storage system or construction of new
facilities, will req•.:__e a new ce_tificat_cn to be submitted to cne Division of
Environmental Management before the new animals are stocked. I (we) also
understand that there must be no discharge of animal waste from this system to
surface waters of the state either through a man-made conveyance or through
runoff from a storm event less severe than the 25-year, 24-hour sto�.:i. The
approved plan will be.filed at the farm and at the office of the local Soil and
Water Conservation District.
Na�.e of Lard Ownar (please Print) : k/c-
Signature: Q+ Date- `
Yea of Yanager, if different from owner (Please print) : 3ohr\
Signature: 9Date:
halm:ZS 6 T
�: A ch ow e in land n. shi on requires notification or a new certification
(if the approved plan is changed) to be submitted to the Division of
Environmental Management within 60 days of a title transfer. ,�V rd�uU'�
DEM USE ONLY : ACNE'ri #� /
3l-365
JA
,,JJ
'v '•':: •o

f!
GENERAL NOTES:
1. ELEVATIONS SHOWN ON THIS PLAN ARE BASED ON AN ASSUMED BENCH-
MARK ELEVATION AND DO NOT REPRESENT MEAN SEA LEVEL DATUM,
2. ANY HEAVY VEGETATION AND/OR ROOT MAT SHALL BE STRIPPED FROM
!PAD AND LAGOON AREAS PRIOR TO PLACING FILL. ROOTS IN EXCESS
OF 2 INCHES IN DIAMETER WILL NOT BE ALLOWED IN FILL SECTIONS.
ANY STUMPS ENCOUNTERED IN LAGOON SIDE SLOPES OR BOTTOM MUST BE
REMOVED.
3. THE SOILS INVESTIGATION DONE BY MURPHY FARMS INDICATES NON --
SUITABLE MATERIAL IN THE PROPOSED LAGOON AREA AND A CLAY LINING
WILL BE REQUIRED, THE BOTTOM AND SIDE SLOPES OF THE LAGOON
SHALL BE UNDERCUT FOR A 1.5' THICK LINER. THE LINER MATERIAL
SHALL BE COMPACTED TO 95% OF THE STANDARD PROCTOR MAXIMUM DRY
DENSITY. THE MURPHY FARMS ENGINEERING DEPT, MUST APPROVE
LINER MATERIAL PRIOR TO PLACEMENT. SEE LINER DETAIL ON SHEET
2.
4. THE LAGOON IS BEING PLACED IN A WET AREA WITH THE WATER TABLE
BEING VERY NEAR EXISTING GRADE. IT IS IMPERATIVE THAT THE
CONTRACTOR INSTALL DRAINAGE MEASURES AT THE START OF THE
PROJECT AND MAINTAIN IT UNTIL ALL GRADING IS COMPLETED,
5. THE GROWER IS STRONGLY ADVISED TO CHARGE THE LAGOON WITH WATER
TO THE LEVEL OF EXISTING GRADE OUTSIDE THE LAGOON AS SOON AS
THE LINER IS COMPLETE, THIS IS IMPORTANT TO GUARD AGAINST
SLOUGHING OF THE LINER MATERIAL.
6. ALL FILL MATERIAL PLACED ON THE BUILDING PAD AND LAGOON
SHALL BE COMPACTED TO 95% OF THE STANDARD PROCTOR MAXIMUM DRY
DENSITY, IT IS RECOMMENDED THAT COMPACTION BE DONE WITH A
SHEEPSFOOT ROLLER.
7. BUILDING PAD ELEVATIONS SHOWN ON THIS PLAN REPRESENT BLDG.
SLAB SUBGRADE, SEE PAD CROSS SECTIONS FOR GRADE REFERENCE
POINT.
B. BUILDING PAD AND LAGOON DIKE SIDE SLOPES ARE 3:1 UNLESS
OTHERWISE NOTED ON PLAN.
9. THE LAGOON DIKE AND SIDE SLOPES MUST BE FERTILIZED, SEEDED AND
MULCHED DOWN TO THE LAGOON BOTTOM, OR TO THE WATER LEVEL IF
CHARGED, BEFORE THE LAGOON CONSTRUCTION CAN BE CERTIFIED.
10. THE CONCRETE BLOCK SPLASH PADS OR OTHER APPROVED SCOUR
PROTECTION DEVICES SHALL BE INSTALLED AT THE DISCHARGE PIPES
BEFORE LAGOON CONSTRUCTION CAN BE CERTIFIED.
11. ANY WATER SUPPLY WELLS PLACED ON THE SITE MUST BE A MINIMUM OF
100' FROM THE CLOSEST POINT OF THE LAGOON.
12. THE STAFF GAUGE SHALL BE FABRICATED AS SHOWN ON SHEET 2 AND
MUST BE INSTALLED BEFORE LAGOON CONSTRUCTION CAN BE CERTIFIED.
THE MURPHY FARM ENGINEERING DEPT. WILL ASSIST THE GROWER AS
NEEDED TO INSURE 114E STAFF IS SET AT PROPER ELEVATIONS.
D!-rRINr, THE= SOILS INVEST1rATI0N, IT WAS DISCi��s;FULp T1-fAT SUBSURFACE
DRAIN PIPE EXIST IN THE PROPOSED LAGOON AREA. PREVIUUb 10 LAGOL}N
CONSTRUCTION A MIN. 6 FT. DEEP TRENCH SHA,_L BE EXCAVATED 5 FT.
OUTSIDE THE FILL LIMITS AROUND THE LAGOON.
14. PROPERTY BOUNDARY !NFOPMATION AS ACQUIRED FROM h, BOUNDARY
SURVEY FOR BENJAMIN OLIVER OUTLAW PROVIDED BY MARSHALL H.
PHILLIPS, RLS, DATED NOVEMBER 1, 1995
LEGEND
- --- ---- - 50 - -
50
FM
IRU
P-1, ..., L-1, ..., 0--1, ...
EXISTING CONTOUR
FINISHED CONTOUR
PVC DISCHARGE PIPES
MINIMUM BUILDING / LAGOON
SETBACK LINE
SWALE % DIVERSION
4' X 8' CONC. BLOCK
SPLASH PAD
STAFF GAUGE
SOIL TEST PIT
PAD, LAGOON, OFFSET
STAKEOUT POINTS
11111 MURPHY-
FARMS
PHONE : (910) 289 - 2111
SEEDING NOTES:
1. ALL DISTURBED AREAS SHALL BE SEEDED, FERTILIZED AND MULCHED AS
SOON AS POSSIBLE AFTER FINAL GRADING IS COMPLETED. THIS
INCLUDES INSIDE SLOPES OF THE LAGOON.
2. PREPARE DISTURBED AREAS FOR SEEDING BY GRADING ALL SURFACE
WATER DIVERSIONS AND SHAPING TO FINAL GRADES SHOWN ON PLAN.
3. APPLY LIME AND FERTILIZER THEN DISK TO PREPARE A 3 TO 4 INCH
SMOOTH SEEDBED. APPLY SEED AND FIRM SEEDBED WITH A
CULTIPACKER OR SIMILAR EQUIPMENT, APPLY MULCH AND SECURE
WITH A MULCH ANCHORING TOOL OR NETTING,
SOIL AMENDMENTS:
2500 LBS OF 10-10--10 FERTILIZER (1000 LBS/ACRE)
5.0 TONS OF DOLOMITIC LIME (2 TONS/ACRE)
250 BALES OF SMALL GRAIN STRAW (100 BALES/ACRE)
SEEDING SCHEDULE:
WINTER
150 LBS OF FESCUE (60 LBS/ACRE) -- SEPT 1 TO NOV 30
100 LBS OF RYE GRASS (40 LBS/ACRE) - DEC 1 TO MAR 30
75 LBS OF RYE GRAIN (30 LBS/ACRE) - nurse crop for fescue
25 LBS OF UNHULLED COMMON BERMUDA GRASS (10 LBS/ACRE)
SUMMER
150 LBS OF PENSACOLA BAHIA GRASS (60 LBS/ACRE) MAR 15 TO JUNE 15
23 i.RS OF HULLED COMMON BERMUDA GRASS (8 LBS/ACRE) -- APRIL 1 TO JULY 31
TOTAL AREA TO BE SEEDED AND MULCHED = 2.5 ACRES (APPROX)
INC.
P. 0. BOX 759 ROSE HILL,
NORTH CAROLINA 28458
EARTHWORK CALCULATION DATA:
CONTROL PNT #129
BURIED REBAR
N 552 7.1534
E = 4385.3818
ELEV. = 95.22
Ciro
PROPERTY LINE
_ 100 FT. OFFSET-.----. ^ ....�... �-
�--- ----. �-`��� F R Ol� P R TY LINE
CONTROL PNT #141
BURIED REBAR I I
N= 5550.7482
E = 5049.8663
ELEV. = 96.36
0
I
PROPOSED ROAD
fr 14' MINIMUM ROAD WIDTH
SEE DETAIL ON SHEET 2
FOR MINIMUM ROAD STANDARDS
�T
--
Z
50' OFFSET (TYP V' !�
.-13 C) rrY hi
# 0-12 i w / vs
Im
$S• TOP OF DIKE
WIDTH. = 12.0'
tiI
� lye
PUMP DATA l 0-9
MYER WHR10 2" SOLID HANDLI yG
PUMP, 1 HP,, 1 750 R.P.M, 230V., 10
PUMP TO BE FURNISHED WITH PI(;GY-BACK----..__
CONTROL SWITCH MYERS CAT. #A'HR10P-2
PRECAST CONC. PUMP CHAMBER
(STANDARD PULL PLUG BOX SIZE WITH
SOLID BOTTOM AND 16" RISER SECTION)..
TOP = 100.47'
BOTTOM = 96.47'
METHOD USED: 5' GRID
TOTAL EXCAVATION = 1536 CY. EXCAVATED CLAY = 0 CY.
PAD AND DIKE FILL = 7681 CY. ADJ.) CLAY LINER = 1625 CY. (ADJ.)
NET = 6145 CY. CLAY BORROW = 1625 CY.
.1 JITARI F Fr)R I INFP = n ry
BORROW = 6145 CY.
1. 'PAD AND DIKE FILL VOLUMES HAVE BEEN ADJUSTED 20% AND THE CLAY LINER
FILL VOLUMES HAS BEEN ADJUSTED 15% FOR SHRINKAGE DUE TO COMPACTION.
2. TOTAL EXCAVATION VOLUME INCLUDES UNDERCUT FOR CLAY LINER.
LAGOON ELEVATION DATA
TOP OF DIKE ELEV. = 105.20
BEGIN PUMPING ELEV. = 103.30
END PUMPING ELEV. = 101.50
FINISHED BOTTOM ELEV. = 95.20
9695
100 FT. OFFSET_
-- ."� FROM PROPERTY L1N
CONTROL PNT #18
BURIED RE13AR
N = 4967.1294
E = 4420.5347
ELEV. = 95.77
-3
D
L-2
0-7 P-5
LOW END OF PAD
ELEV. = 98.55'
I
60' RADIUS 0-6
ITRUCK TURN AROUND
I
I
_ - 97 9E, -
GRAPHIC SCALE
40 0 20 40 w 100
{ IN FEET
1 inch = 40 fL
B & 0 NURSERY
1 - 2tjoo NURSERY
F
I
97�
a f
o '
d �
.- Z ;
I
O
10
04
154.00'
L-
0-14
II
jI�
I
4,
III!
3
�I
r!
If
P
75 L.F. 3" PVC PIPE
r
I
LAGOON INV. ELEV. 103.3`�
I
ao
t I 1
Ifs
I
1
■
f��Il
f Till
$ 2 +� I
CL
O
Al
180.00'
P-
I I+
PAD 'o
I JII
- 0.25% SLOPE C7�
c'�
I
�•'
I
I I�
0 ' �m
16 r
00
°"
I
BLDG. -�
FEED
TANKS I'
--.---
J
0-4 i.
LOADOUt �
CHUTE
HIGH
ND OF PAD
f
ELEV.
- 99.00'
I�
I
QD
I
i 0-5
I
cs
t
d
PROPERTY LINE
C16NTROL
PNT #1
i
i� V 717 7
Mk DATE DESCRIPRON
BURIED REBAR L_-EXISTING IRON PIPE
N' - 5000.0000 N = 4987.3722
E = 5000.0000 E = 5010.4141
ELEV. = 1 DO �J
OWNER: OLIVER OUTLAW
'ADDRESS: 1769 WEST WARD BRIDGE RD.
WARSAW, N.C. 28398
PHONE: HOME: (910)-293-7360
BUS.: (910)-293-7749
I
ONSLOW CC9UNTY
DRAWN BY: SAT
NOV. 23, 1 9,5 I
I
CHECKED BY- JST
[SS1HLJ1 E E T 1 0 2
SCALE: 1" 40'
104"" CAR
4
l•PZ
Sf AL
19851
•O •.��YCI NtvE� :�
"It
Cj

CEMENT BLOCK PAD
OVERHANGING LIMBS, POWER UNM ETC.
d
LID
r�
F�
v
C\.I
Zf
0
a
a
.y
p _-
0
L0
r♦
4
Ir
C]
Ca
ROAD ELEV . EXISTINk,
— 1 5' CLAY LINER
-- - PAD WIDTH 80,00'
-rlF ---- BLDG. WIDTH - 55.00'
A ci A
A CONCRETE PAD t
a 4, a 4 e
_ S
Ll, 1
BUILDING PAD SECTION (WIDTH)
REF END GRADE REFERENCE POINT
3
FEED TANY, PAD
LOW ENO GRADE -�
RFFFRFN('.E POINT
PAD LENGTH 180.00' —#
BLDG. LENGTH - 162.00'
1/4% SLOPE
CONCRETE PAD
BCC'. -DING PAD SECTION (LENGTH)
INStOE TOP OF DIKE
STAKING POINT
w'
1 I
UNSUITABLE
,1�1LS
1.5' CLAY UNER
LINER/DIKE CROSS SECTION
MURPHY`
FARMSINC.
P. O. BOX 759 ROSE HILL,
PHONE : (910) 289 - 2111 NORTH CAROLINA 28458
12.00' }
HORIZ. OFFS£ 1 FOR
CLAY LINER . 4 14'
TOP OF DIKE
STRIP TOPSOIL BEFORE FILLING DIKE
ExISTiNG GPADE
B & 0 FARMS
1 - e6OO NURSERY
—1 f 40
PIPE SUPPORT
DISCHARGE T,*3f
NOTES
1, THE GROWER MAY USE EITHER
CONCRETE BLOCK SPLASH PAD CAR
FLEXIBLE PIPE SCOUR PROTECTION
DL- VICE
2. THE SPLASH PAD SHALL EXTEND
A MINIMUM OF 1.0' UPSLOPE OF THC
PIPE END TO 4.0' BEYOND THI` TOE
OF THE SLOPE
3. PLASTIC PIPE SHALL_ BE LONG
ENOUGH TO EXTEND A MINIMUM OF
4.0' FLAT ALONG THE LAGOON
BOTTOM
WAIN OVERHANG OVER SPA'SHPAD - 1 0'
PIPE SUPPORT SHALL Bf If` CONCRETE EILOCA SHALL BE LAID
BACKFILLED WITH CLAY TOGETHER Th>4TLY WITH NO
AND COMPACTED GAPS BETWEEN
4.0 ' MIN
FLEXIBLE PLASTIC PIPE
RT
44p4q�JI
I-0" WIN
PIPE SUPPORT SHALL BE
BA(I�FILLED WITH CLAY
AND f_OMPACTED
FLEXIBLE PIPE SHALL SLIDE OVER
D11SC79ARGE PIPE A MINIMUM OF I'
ANU SHALL BE SECURED WITH SCREWAI$
- ___-I f'_" 4 0' MIN
SCOUR PROTECTION DEVICES
18' +/- FROM INSIDE TOP Of DIKE.
STAFF GAUGE
lF' (* F'VSf I(A'
ELEVA AON
NT k£D
DEEP NOTCHES (TYP)
VT W7E
17 RED
x 8'
kTED POST
AROUND STAFF GAUGE
Y AND COMPACT
IUR Y OEP TH
I �
20' MIN OVERHEAD CLEARANCE
FROM HIGH POINT OF ROADBED
l-�-�-- OVERHANGING LIMBS
1 TRIMMED TO T1' MN.
w000s FROM Ct EA01 SIDE (MOODS
I
22' MIN
DITCH TO DITCH
le11IK
ALL WEATHER TRAVEL WIDTH
I I
1 /2-/F'T.
1
COMPACTED WELL -DRAINED ROADBED 4
SUITABLE FOR ALL WEATHER CONDITIONS SLOPES.
DITCH
5LOPES
SHOULDER DITCHES
PROVIDE ADEQUATE OUTLET FOR
SHOULDER DITCHES
MINI�UM REQUIRED FARM ROAD
I
STATE MAINTAINED ROAD - PAVED OR SOL
T� ROADSIDE DITCH
t 40 AT
ART
60, MIN
50' MIN. LE GIN CLEARING
15' MIN. DIA. CULVERT
I
I
�Cuni TY GATES
I
END OF TAPER/SECURITY
I GATE LOCATION
ENTRANCE MUST BE PLACED SO
THAT 1/4 MILE VISIBILITY IS g
PROVIDED IN BOTH DHRECTONS ' (K 14' MIN. ALL WEATHER TRAVEL WIDTH
22` MIN. ; DITCH TO � DITCH
MINIMUM ENTRANCE REQUIREMENTS
1
POWER CORD
LIFT --OUT CHAIN
4:4 TREATED POST
.AJNCT)ON BOX FOR
PUMP TIE-IN
RUN TO DISCONNECT IN
BLDG FOR PUMP CONTROL
8" PVC DISCHARGE PIPE
8' COUPLIN
�e
2" SCH 40 PVC
KEY 'ONT MATH f THREADED UNION
UUTYI ��µRTUHBER CHECK VALVE
A
PIT! RECHARGE BLDG.
PUMP CHAMBER
DUPLIN COUNTY
DRAWN BY. SAT
NOV. 231 1995
CHECKED 8Y: ,Jsr
SHEET 21OF 2
a
SCALE; NONE
A
h
2" . Y REDUCER
FORCE MAIN TO LAGOON
i
!" SCH 40 PVC_
. PIPE rk FTGS,
•`�a�` ''• -j 5
� SfAI 10
19851