310297_HISTORICAL_20171231

NORTH CAROLINA
Department of Environmental Qual

ANIMAL WASTE UTILIZATION PLAN
RECEIVED ! DENR 1 DWQ
AQUIFER-PRnTFrT1nN SFMON
Producer: MIKE RABON APR 2 8 2�0�
Location: 446 NC & US 117
WARSAW NC 28398
Telephone: [phone]
Type Operation: Existing Wean to Feeder Swine
Number of -Animals: 7800.00 pigs
(Design Capacity)
STORAGE STRUCTURE: Anaerobic Waste Treatment Lague cEjVIEJD
APPLICATION METHOD: Irrigation APR 2 7 2009
The waste from your animal facility must be land appliW:ert a�.
specified rate to prevent pollution of surface.water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops
in the fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil
tests -are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste Do not apply
more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities_
3. Normally waste shall be applied to land eroding at less than
5 tons per acre per year. Waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. bo not apply waste on saturated soils, when it is raining,
or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed
:-� under DWQ regulations.
Page: 1

ANIMAL WASTE UTILIZATION PLAN
5. Wind conditions should also be considered to avoid drift and
downwind odor problems.
G. To maximize the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more than 30
days prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. if
you choose to change methods in the future, you need to revise this
plan. Nutrient levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from your
waste management facility. In some cases you may want to have plant
analysis made, which could allow additional waste to be applied.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
This waste utilization plan, if carried out, meets the requirements
for compliance with 15A NCAC 2H .0217 adopted by the Environmental
Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
7800 pigs x .40 tons waste/pigs/year = 3120 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
7800 pigs x .48 lbs PAN/pigs/year = 3744_lbs. PAN/year
Applying the above amount of waste is a big job. You should plan
time and have appropriate equipment to apply the waste in a timely
manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
Page: 2

ANIMAL WASTE UTILIZATION PLAN
TABLE 1: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & CLASS-..
CROP
YIELD
LES
COMM N
LES
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
or--------
APPLY
RESID.
APPLIC
METH
N
TIME
71924
P1
NOB
BP
4.6
230
0
2.06
473.8
I
+APR-
A100
71924
SG
I-Pi
11
150
10
12.06
1103
APR
71924
P2
NOB
BP
4.6
0
I
1230
14.09
194-0.7
+APR-
OCT
' 924
-P2
SG
1
Q
I
150
14.09
1.204.5
+SEP-
APR
435
P3
NOB
BP
4.6
0
I
1230
16.94,11596.2
+APR-
OCT
435
P3
SG
1
0
I
150
16.94
1347
+SEP-
APR
435
P4
NOB
BP
4.6
0
i
1230
11.8
1414
+APR--
OCT
435
P4
SG
1
I
Iso
lo
11.8
�90
+SEP-
APR
435
P5
NOB
BP
4.6
0
I
1230
11.52 1349.6
+APR-
OCT
435
-P5
SG
1
150
0
11.52
176
I
+SEP-
Page: 3

ANIMAL WASTE UTILIZATION PLAN
TOTAL14594.8
- - Indicates that this field is being overseeded (i.e.
interplanted) or winter annuals follow summer annuals.
+ - Dates shown reflect optimum uptake periods for nutrients. Waste
appilcation may begin up to thirty(30) days prior to planting or.
green -up of forages, and extend past optimum dates shown if
plant growth, pumping conditions, and PAN loading rates permit-.
VOTE: The applicator is cautioned that P and K may be over applied
while meeting the N requirements. In the future, regulations
may require farmers in some parts of North Carolina to have a
nutrient management plan that addresses all nutrients. This
plan only addresses nitrogen.
Page: 4

ANIMAL WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
See required specification 2.)
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
'**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
----
or
---------
APPLY
RESID.
APPLIC
METH
N
TIME
END
TOTAL 10
- Indicates that this field is being overseeded (i.e. interplanted) or
winter annuals follow summer annuals.
+ - Dates shown reflect optimum uptake periods for nutrients. Waste
application may begin up to thirty(30) days prior to planting or'
green -up of forages, and extend past optimum dates shown if
plant growth, pumping conditions, and PAN loading rates permit.
In interplanted fields (i.e. small grain, etc, interseeded
in bermudagrass), forage must be removed through grazing,
hay and/or silage. Where grazing, plants should be grazed
when they reach a height of six to nine inches. Cattle
should be removed when plants are grazed to a height of four
inches. In fields where small grain, etc, is to be removed
for hay or silage, care should be exercised not to let small
grain to reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too
high and this will definitely interfere with stand of
bermudagrass. This loss of stand will result in reduced
yields and less nitrogen being utilized. Rather than
cutting small grain for hay or silage just before heading as
is the normal situation, you are encouraged to cut the small
grain earlier. You may want to consider harvesting hay or
silage two to three times during the season, depending on
time small grain is planed in. the fall.
The ideal time to interplant small grain, etc, is late
September or early October. Drilling is recommended over
broadcasting. Bermudagrass should be grazed or mowed to a
height of about two inches before drilling for'best results.
Page: 5

. ANIMAL WASTE UTILIZATION PLAN
1 S
** Acreage figures may exceed total acicage in Melds d112 t0
overseeding.
* ibs AW N (aiYimal waste nitrogen) equalo total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and 2 above:
CROP CODE
CROP
UNITS
PER UNIT
BP
SG
HYBRID BERMUDAGRASS-PASTURE
SMALL GRAIN OVERSEEDED
TONS
AC
50
50
TABLE 1
TABLE 2
TOTAL
TOTALS FROM TABLES 1 AND 2
WETTABLE
LB§ AW N U90
_ACRES
16.41
4594.5
0
0
16.41
4594.8
* BALANCE
-850.8
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.
n
Page: 6

ANIMAL WASTE UTILIZATION PLAN
** This number must be less than or equal to 0 in order to fully
utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffers, filter strips along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than
the acres shown in the tables.
See attached map showing the fields to be used for the utilization of
animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient
rich and will require precautionary measures to prevent over application
of nutrients or other elements. Your production facility will produce
approximately 592.8 pounds of plant available nitrogen per year in the
sludge.
If you remove the sludge every 5 years, you will have approximately 2964
pounds of PAN to utilize. Assuming you apply this PAN to hybrid
bermudagrass hayland at the rate of 300 pounds of nitrogen per acre, you
will need 9.88 acres of land. If you apply the sludge to corn at
the rate of 125 pounds of nitrogen per acre, you will need 23.712-acres
of land. Please be aware that these are only estimates of the PAN and
land needed. Actual requirements could vary by 25% depending on your
sludge waste analysis, soil types, realistic yields, and application -
methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the
soil at the time of -irrigation such that runoff or ponding occurs. This
rate is limited by initial soil moisture content, soil structure, soil
texture, water droplet size, and organic solids. The application amount
should not exceed the available water holding capacity of the soil at the
time of irrigation nor should the plant available nitrogen applied exceed
the nitrogen needs of the crop.
If surface irrigation is,the method of land application for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables 1 and 2. Failure to apply the recommended rates and
Page: 7

ANIMAL WASTE UTILIZATION PLAN
amounts of nitrogen shown in the tables may make this plan invalid.
The following table`is provided as a guide for establishing application
rates and amounts.
I
i
I
I
jApplication
RatelApplic. Amount
Tract
Field
Soil Type
crop
(in/hr)
(inches)
435 !�
P3
NOB
BP
I .50
*1.0
E
435
P4
NOB
BP
.50
*1.0
435
P5
NOB
I BP
I .50
I *1.0
435
--P3
SG
f .5
*1
435
--P4 I
f SG
.5
*1
435
--P5
SG
.5
*1
71924
P1
NOB
BP
.50
*1.0
!71924
J.P2 !
NOB
I BP
.50
*1.0
71924
-P1 I
SG
.5
*1
�124
j --P2
SG
.5
*1
Page: 8

ANIMAL WASTE UTILIZATION PLAN
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations, the application amount shown cannot
be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180.00 days of temporary storage and
the temporary storage must -be removed on the average of once every
6.00 months. In no instance should the volume of the waste be stored
in your structure be within the 25 year_24 hour storm storage or one
foot of freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply the
correct rates to the. acres shown in Tables 1 and 2. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may
make this plan invalid.
Call your technical specialist after you receive the waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate prior to applying the waste.
NARRATIVE OF OPERATION.
THIS PLAN IS WRITTEN ON AN WETTEABLE ACRE FOOTPRINT BY PULLS 1-5
Page: 9

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for -use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but -not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
5. Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
5. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "weather
and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does'not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be considered.
Page: 10

WASTE IITILIZATION PLAN
REQUIRED SPECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is.applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to
wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly into water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates!in a manner that causes no runoff or drift from
the site. I
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs., and
other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
- Pages 11

` WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
18. If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected�on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can be used in a'rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22. Waste shall be tested within 60 days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when these
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for'three (3)
years. Waste application records for all other waste shall be
maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North
Carolina regulations.
Page: 12

ANIMAL WASTE UTILIZATION PLAN
WASTEUTILIZATION PLAN AGREEMENT
Name of Farm:RABON NURSERY 123
Owner/Manager Agreement
I (we), understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
North Carolina Division of Water Quality (NCDWQ).before the new
animals are stocked. I (we) also understand that there must be no
discharge of animal waste from this system to surface waters of the
state from a storm event less severe than the 25-year, 24-hour
storm. The approved plan will be filed on -site at the farm office
and at the office of the local Soil and Water Conservation District
and will be available for review by NCDWQ upon request.
Name of Facility Owner: MIKE RABON
(Please print)
Signature: Date: 0
Name of Manager(If different from owner):
Signature:
Date:
Name of Person Preparing Plan: (Please print)JOHNNY L. LANIER
Affiliation:DUPLIN SOIL AND WATER CONSERVATION DISTRICT
Phone No. 910-296-2120
Address (Agency): PO BOX 219
KENANSVILLE NC 28349
Signature: Date: 2 2 0
Page: 13

n
Wettable Acres Determination Certification
Name of Facility:._.91" M)rgeLi 1, .2, 95 Facility Number:! _-�9`7
Owner(s) Name: ;k_e�R o, Le," _ _ Phone No:ft 19 3 - 71, � O
Mailing Address: W u 5 17 La n jr A a w
By signing this form, the facility owner and Technical Specialist acknowledge the completion of the
Wettable Acres Determination. All necessary Wettable Acre Determination Field Data Sheets and
calculations were completed to conduct a Wettable Acre Determination. The facility's Waste
Utilization Plan has been amended as necessary to reflect actual wetted acreage. A copy of all
worksheets, calculations, and other Wettable Acres Determination documents, along with the
applicable Waste Utilization Plan and Wettable Acre Determination Certification will be filed with
the local Soil and Water Conservation District. A copy will also be kept on site with the Certified
Animal Waste Management Plan. Any future modifications must be approved by a technical
specialist and filed with the Soil and Water Conservation District prior to implementation. If any
modifications to the existing irrigation system or any new irrigation equipment was required to
adequately address the waste management needs of this facility, an Irrigation Specialist or
Professional Engineer has certified the design and installation below.
Owner Name:
Owner Signature:
Technical Specialist Name:_,ja)f,%r _, L o vk < < v- T
Technical Specialist Signature: Date:
If assisted by an Irrigation Specialist or Professional Engineer please read and sign below:
Animal waste application equipment has been designed or modified to apply waste as necessary to
accommodate the waste management plan and according to NRCS Standards. Animal waste
application equipment has been installed according to NRCS Standards and is ready for use.
Irrigation Specialist/PE Name:
Irrigation Specialist/PE Signature: Date:
Submit this form to:
Attn: Sonya Avant
Non -Discharge Compliance Unit
Division of Water Quality
1617 Mail Service Center
Raleigh, NC 27699-16I7
WADC - 7/99

... � • ' - -' -i. �' •. __{ - .1'= '* s r �3 �: ra.� tits . � ""�tc�„�i:_ ` � -i � ���' i '' ':. '.". �.R' �.
CR1IP Wcttsbls Acts Tn Cc .
'-+�..,..�-c
' am �.
_• -_ ....
Farm Number (Identification)' 3 q 7 - Feld Numbef •.I � . _ • -
1 ,{Identification}
2. Irrigation System Designation usting Irrigation System = . Newt Expanded Irrigation Sy3_
3. Number of Travel Lanes # Interior Lanes �_ # Exterior Lanes 22Y Meet] Length of pull(I,i)
# Interior Lanes _ D # Exterior Lanes S3 S Ifeet] Length of pull( ,2)
# Interior Lanes_ # Exterior Lanes Meet] Length ofpull(L3)
4. Wetted Diameter 10 [feet] From field data sheet
5. Spacing Hydrant Spacing [feet] (as percent of wetted diarrieter]
6. Hydrant Layout Multiple Hydrants Single Hydrant Excessively spaced Hydrants
7. Read the irrigated area per travel puU for the given wetted diameter from the appropriate table and column
based on pattern, spacing, and travel lane location.
Travel Lane Length (Li) Interior or __L__Exterior (Lane/Hydrant)
,$ 9 (a) Acres start end of pull from Table F i0 f Column -
tj 417_ (b) Acres muddle portion of pull (LI)
{Pull Length?(feet] X Wetted Width.2,�D [feet]} 143,560
0 (c) Acres stop end of pull from Table , `� _ 0_ f Column C-
• 0 a Total acres for Travel Lane Length (LI) (Sum: a + b + c)
Travel Lane Length (L2) Interior or ') Exterior (Lane/Hydrant)
• 5 ? (a) Acres start end of pull from Table E 90- Colurru-t •
S� (b) Acres huddle portion of pull (L1)
{Pull LengthS=• (feet] X Wetted NVidth.2ai� [fiet]} 143,560
O _ (c) P_sres -top end of pull from 7 able Coli_--,r. _ G•
J. T otal acres for Travel Lane Length (L2) (Sum: a _ b _ c)
Travel Lane Length (U) Int_;;or or _Exterior (Lanerciydr:n:;a
.s R (a) Acres start en u of put! from Table � Yo t Coiu-r .�
3 .; (b) Acres ruddie portion of pull (L 1)
Pull Lenard q7o [leer] X i�"erred �ti"id:h [remit]} r .3;�54
b (c) Acres stop erd n°pull iron Table E FO V Colurv^ C . _-
�_ Total acres for Travel Lane Length (L3) (Sum: a ; b + c)
s e tabulated _� ed e a •, e- travel be� P , n ti;e
5. �.iu.:apt•.• the tabu ?t d irria_t�L a_r.._a., value p . tra. l p�.�i b; t�-�., rl�:n:, � fl= t.l:s a: a:. ca..,Yory ix
field. Sum all of these and t' 's is the total lmaa:ed acreage for the field.
t;1,1 (a) Acres per Travel Lane Length (LI) X r Lams -- , D Acres
(b) Acres per Travel Lar.-- Length (L2) X .2 -,-Lanes 0 Gl Acres
(c) Acres per Travel Lane Length (L3) X 3 r Lazes = Acres
13, 0 q Total CA-VN"v1P Wettable Acres for field (Sum: Sa —' 8b + 8c)
We_,able Acre Computational Worksheet Completed by: ^ �,.,�, — Date
1

'�' • i•.' _ w � :i'�,fi -F _ '•;i�� '�t�=�!stF~r•�� �ti •'u! ia�.• �':Y- - �.
CA➢ WP W4041 .. #` J;� x y ;.� ..c� '• r _ '` ,y:s� ` _ �a { �., ' Tea �Gta Coa `
ri
_ Y'• •- .� i•.:.t•. _ .:. ��� �,r'i+'+..-1..�,'i�r{-��•..::'W-�� %.t ✓ff i �wii�t-. r .t�:
Hose • c8 is n
- _ . _ ' ..:-. C011�IPUT= TIO '�VO� �_ �'.• �� :...- • . ,
§.74t. Farm Number (Identification) cation) -7 Field Nuf6i (Id ehtifi cation) {: :
2. irrigation System Designation _'LEzisting Irrigation System -New/Expanded Irrigation %;ft
=' tAl . "
3. Number of Travel Lanes #Interior Lanes._ # Exterior Lanes /,'S�feet] Length of pu1)
# Interior Lanes S_ # Exterior Lanes S &C [feet) Length of P.U, )
# Interior Lanes # Exterior Lanes [feet] Length of pull(L3)
4. Wetted Diameter / J [feet] From field data sheet
5. Spacing Hydrant Spacing [feet] �".'� [as percent of wetted diameter]
6. Hydrant Layout Multiple HydrantsSingle Hydrant Excessively spaced Hydrants
7. Read the irrigated area per travel pull for the given wetted diameter from the appropriate table and column
based on pattern, spacing, and travel lane location.
Travel Lane Length (L1) Interior or 4
L_Exterior (Lane/Hydrant)
.- $ (a) Acres start end of pull from Table 9� Column
(b) Acres middle portion of pull (LI) _
(Pull Length/?1_X ?;?O [feet]) 143,560�ti
0 (c) Acres stop end of pull from Table E 5�d 14- Colurnn
V Total acres for Travel Lane Length (LI) (Sum: a + b + c)
Travel Lane Length (L2) Interior or _Exterior (Lane/Hydrant)
(a) Acres start end of pull from Table ColurrLn-��_
(b) Acres middle portion of pull (Ll)
(Pull Length��� [feeC] X Vetted «'i�dth /Su [fe:z]} 143,560
(c) ?.gyres =top end of pull from able L 70 Coll_�n _
L_� 0,Total acres for Travel Lane Length (L2) (Sum: a + b �- c)
Travel Lane Length (L3) Interior or Ex erior (Lane.!Hydrant)
(a) Acres start end; of pull from Table Cois07;--1
(b) Acres r:uddie portion of pull (LI),
{Pull Lenz'n [fee=] X We -Led Width [i4e:]) 43,560
(c) Acres stop erd nrpu!! from Table Colurn.-1
Total acres for Travel Lane Length (L3) (Sum: a + b + c)
I ; a to va `d ea a value per a ,' `,-er ,l' _y � t�"'
S_ 11=.:�t�p:�• the LabLla�..d irrigated acr� 7., ti 11.. p . travel p��i b the n�:rn o"p�.:s o. acil cat„Yoy ia-t
eld. Surn all of these and this is the tctairrigated acreage for the field.
{ 0 (a) Acres per Travel Lane Length (L1) X L/ = La-ies = , �� Acres
_s _ (b) Acres per Travel La:ie Length CL2) X S� r Lanes — ,� Acres
(c) Acres per Travel Lane Length (L3) X u La-nes -- Acres
Total CANVINIP Wettable Acres for field (Sum: Sa _ 8b + 8c)
f
Wertable Acre Computational Worksheet Completed by<:)�
u

WETTABLE 'ACRES
IRRIGATION SYSTEM DESIGN PARMATERS
and
COMPUTATIONAL WORKSHEET SUMMARY
Landowner / Operator Name Mike Rabon
Adress . 446 NC 50 & US 117
Warsaw NC 28398
Telephone [phone]
TABLE 1 - Field Specifications
County Du lin
Date 2121101
Facility # 31-29T
Tract
Number
Hydrant
or
field (1)
Number
acres
start end
wetted
area
acres
middle
wetted
area
acres
stop and
wetted
area
ApproArnate
Maxlmun
Useable Site
of field (2)
acres
Table
column
Length
of
pulls
In feet
Width
or
pulls
In feet
Soil Type.
Slope
96
G e
McArnun
Application
Rate (3)
(Mr)
Mwdumn
Application
per Irrigation
cycle (3)
inches
71924
P1
0.59
1.47
0
2.06
E90+
B-C
226
280
NOS
0-5
bermude / small grain
0.5
1
71924
p2
0.59
3.5
0
4.09
E90+
B-C
635
280
NOB
0-5
bermuda / small grain
0.5
1
435
p3
0.59
6.35
0
6.94
E90+
B-C
970
280
NOB
0.5
bermuds / small rain
0.5
1
435
p4
0.59
1.21
0
1.8
E90+
B-C
165
280
NOB
0-5
hermude / small grain
0.5
1
435
p5
0.16
1.52
0
1.52
E90+
B-C
395
150
NOS
0-5
bermuda / small grain
0.5
1
1 see attached map.
2 Told field acreage minus required buffer areas.
3 Refer to N.C. Irrigation guide, Field Office Technical Guide, Section It G. Annual application must not exceed the agronomic rates for the soll and crop used.
Wettable Acre Computational Worksheet Completed by: lJohnny Lanier Date 1,2 ,'GI D J
i

4 Wks 'F
we
cil
IN
qi-
NA
_��{Y �� �y`r,��c, 3�� •I � `�� r .� o p� o o`�-, � _ -_ Ste',^ ��✓
to #.••. '^.f " - - - ' . \ �i - ' i
�� o ,���y-. err,-�i° �� ''a'J�� - = � .. ',iJ - • •- ..SLL-
mo
.17
i• - may'' �- c � ,J "s � ` i - � f

Michael F. Easley, Governor
William G. Ross Jr_, secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P_ E., Director
Division of Water Quality
May 1, 2003
Mike Rabon
Rabon Nursery 1, 2 & 3
250 George Garner Rd.
Warsaw NC 28398
Subject: Certificate of Coverage No. AWS310297
Rabon Nursery 1, 2 & 3
Swine Waste Collection, Treatment,
Storage and Application System
Duplin County
Dear Mike Rabon:
On April 28, 2003, the North Carolina General Assembly ratified - Senate Bill 733 which directs the
Division of Water Quality (Division) to extend the expiration date of the Swine Waste Operation General
Permit AWG100000. Therefore, the General Permit has been re -issued by the Division to extend the
expiration date to October 1, 2004. During the period of this extension the Division will be working with
all interested parties on the development of a new version of the Non -Discharge General Permit.
In accordance -with your application received on March 21, 2003 and in accordance with the directive of
Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to Mike
Rabon, authorizing the operation of the subject animal waste collection, treatment,_ storage and land
application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AWS310297 which expired on April 30, 2003.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Rabon Nursery 1, 2 & 3, located in Duplin County, with an animal capacity of
no greater than an annual average of 7800 Wean to Feeder swine and the application to land as specified
in the facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or
Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary,
they may be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a
rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until October 1, 2004. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property. AWA
AMENER
Non -Discharge Permitting Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
Customer Service Center
An Equal Opportunity Action Employer
Internet httpJ/h2o.enr.state.ne.us/ndpu
Telephone [phone] Fax [phone]
Telephone [phone]
50% recycled1109'o post -consumer paper

Upon abandonment or depopulation for a period of four years or more, the Pennittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per NRCS standards a 100 foot separation shall be maintained between water supply wells and any
lagoon or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If -you wish to -continue -the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal inusfbe filed-at-least-180.days-p6or to expiration.
This COC is not automatically transferable. A name ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, -or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Wilmington Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Sue Homewood at [phone] ext. 502.
Sincerely,
for Alan W. Mimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
Wilmington Regional Office, Water Quality Section
Duplin County Health Department
Duplin County Soil and Water Conservation District
Permit File AWS310297
NDPU Files

Wettable Acres Determination Certification
Name of Facility:_ a6Facility Number:_-Al2
Owner(s) Name: leaµ,-_ a L s" - Phone No:ybAjj - 24b D
Mailing Address:_ 4 � L .5-0 _y,4. 1 t ? O n *s gut Al L 2.2 3 a it
By signing this form, the facility owner and Technical Specialist acknowledge the completion of the
Wettable Acres Determination. All necessary Wettable Acre Determination Field Data Sheets and
calculations were completed to conduct a Wettable Acre Determination. The facility's Waste
Utilization Plan has been amended as necessary to reflect actual wetted acreage. A copy of all
worksheets, calculations, and other Wettable Acres Determination documents, along with the
applicable Waste Utilization Plan and Wettable Acre Determination Certification will be filed with
the local Soil and Water Conservation District. A copy will also be kept on site with the Certified
Animal Waste Management Plan. Any future modifications must be approved by a technical
specialist and filed with the Soil and Water Conservation District prior to implementation. If any
modifications to the existing irrigation system or any new irrigation equipment was required to
adequately address the waste management needs of this facility, an Irrigation Specialist or
Professional Engineer has certified the design and installation below.
Owner Name:
Owner Signature: Date:' a dl Le /
Technical Specialist Name: L 0 V. aV-
Technical Specialist Signature: A Date: i
If assisted by an Irrigation Specialist or Professional Engineer please read and sign below-:
Animal waste application equipment has been designed or modified to apply waste as necessary to
accommodate the waste management plan and according to NRCS Standards. Animal waste
application equipment has been installed according to NRCS Standards and is ready for use.
Irrigation Specialist/PE Name:
Irrigation Specialist/PE Signature: Date:
Submit this foam to:
Attn: Sonya Avant
Non -Discharge Compliance Unit
Division of Water Quality
1617 Mail Service Center
Raleigh, NC 27699-1617
WADC - 7/99

i
ANIMAL WASTE UTILIZATION PLAN
Producer: MIKE RABON
Location: 446 NC & US 117
WARSAW NC 28398
Telephone: [phone]
Type Operation: Existing Wean to Feeder Swine
Number of Animals: 7800.00 pigs
(Design Capacity)
STORAGE STRUCTURE: Anaerobic Waste Treatment Lagoon
APPLICATION METHOD: irrigation
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops
in the fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply
more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall be applied to land eroding at less than
5 tans per acre per year. Waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on saturated soils, when it is -raining,
or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed
under DWQ regulations.

ANIMAL WASTE UTILIZATION PLAN
5. Wind conditions should also be considered to avoid drift and
downwind odor problems.
6. To maximize the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more than 30
days prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. If
you choose to change methods in the future, you need to revise this
plan. Nutrient levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from your
waste management facility. In some cases you may want to have plant
analysis made, which could allow additional waste to be applied.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
This waste utilization plan, if carried out, meets the requirements
for compliance with 15A NCAC 2H .0217 adopted by the Environmental
Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
7800 pigs x .40 tons waste/pigs/year = 3120 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
7800 pigs x .48 lbs PAN/pigs/year = 3744.lbs. PAN/year
Applying the above amount of waste is a big job. You should plan
time and have appropriate equipment to apply the waste in a timely
manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.

f
ANIMAL WASTE UTILIZATION PLAN
TABLE 1: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
--------
APPLY
RESID.
APPLIC
METH
N
TIME
71924
Pi
NOB
BP
4.6
0
473.8
I
+APR -
CT
71924
4
!Z
�-P1
I
II
I
10
rOM
1103
+SEP-
PR
71924
P2
NOB
BP
4.6
0
940.7
I
rMOV
1
JEEM
+APR -
CT
71924
-P2
SG
1
0
-
1
I
I
1
IWO
1.204.5
+SEP-
PR
435
P3
NOB
BP
4.6
0
I
JaW111596.2
+APR -
CT
435
--P3
SG
110"lil0347
I
+SEP-
PR
435
P4
NOB
BP
4.6
0
I
PM
1414
+APR --
CT
435
--P4
SG
1J
0
90
i
+SEP-
PR
435
P5
NOB
BP
4.6
0
349.6
I
JIM
+APR -
CT
435
_PS
SG
1
D
76
I
I",_-
+SEP-
PR

ANIMAL WASTE UTILIZATION PLAN
END
TOTAL14594.8
- - Indicates that this field is being overseeded (i.e.
interplanted) or winter annuals follow summer annuals.
+ - Dates shown reflect optimum uptake periods for nutrients. Waste
appilcation may begin up to thirty(30) days prior to planting or,
green -up of forages, and extend past optimum dates shown if
plant growth, pumping conditions, and PAN loading rates permit.
°TE: The applicator is cautioned that P and K may be over applied
while meeting the N requirements. In the future, regulations
may require farmers in some parts of North Carolina to have a
nutrient management plan that addresses all nutrients. This
plan only addresses nitrogen.

ANIMAL WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
See required specification 2.)
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
----
or
------
APPLY
RESID.
APPLIC
METH
N
TIME
END
TOTAL 10
Indicates that this field is being overseeded (i.e. interplanted) or
winter annuals follow summer annuals.
Dates shown reflect optimum uptake periods for nutrients. Waste
application may begin up to thirty(30) days prior to planting or
green -up of forages, and extend past optimum dates shown if
plant growth, pumping conditions, and PAN loading rates permit.
In interplanted fields (i.e. small grain, etc, interseeded
in bermudagrass), forage must be removed through grazing,
.hay and/or silage. where grazing, plants should be grazed
when they reach a height of six to nine inches. Cattle
should be removed when plants are grazed to a height of four
inches. In fields where small grain, etc, is to be removed
for hay or silage, care should be exercised not to let small
grain to reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too
high and this will definitely interfere with stand of
bermudagrass. This loss of stand will result in reduced
yields and less nitrogen being utilized. Rather than
cutting small grain for hay or silage just before heading as
is the normal situation, you are encouraged to cut the small
grain earlier. You may want to consider harvesting hay or
silage two to three times during the season, depending on
time small grain is planted in. the fall.
The ideal time to interplant small grain, etc, is late
September or early October. Drilling is recommended over
broadcasting. Bermudagrass should be grazed or mowed to a
height of about two inches before drilling for'best results.

ANIMAL WASTE UTILIZATION PLAN
** Acreage figures may exceed total acreage in fields due to
overseeding.
* lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and 2 above:
CROP CODE
CROP
UNITS
PER UNIT
BP
SG
HYBRID BERMUDAGRASS-PASTURE
SMALL GRAIN OVERSEEDED
TONS
AC
50
5Q
TABLE 1
TABLE 2
TOTAL
TOTALS FROM TABLES 1 AND 2
WETTABLE
LBS AW N USED
_ACRES
16.41
4594.8
a
0
16.41
4594.8
* BALANCE
-850.8
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.

ANIMAL WASTE UTILIZATION PLAN
*** This number must be less than or equal to 0 in order to fully
utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffers, filter strips along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than
the acres shown in the tables.
See attached map showing the fields to be used for the utilization of
animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient
rich and will require precautionary measures to prevent over application
of nutrients or other elements. Your production facility will produce
approximately 592.8 pounds of plant available nitrogen per year in the
sludge.
If you remove the sludge every 5 years, you will have approximately 2964
pounds of PAN to utilize. Assuming you apply this PAN to hybrid
bermudagrass hayland at the rate of 300 pounds of nitrogen per acre, you
will need 9.88 acres of land. If you apply the sludge to corn at
the rate of 125 pounds of nitrogen per -acre, you will need 23.712-acres
of land. Please be aware that these are only -estimates of the PAN and
land needed. Actual requirements could vary by 2511 depending on your
sludge waste analysis, soil types, realistic yields, and application
methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the
soil at the time of irrigation such that runoff or ponding occurs. This
rate is limited by initial soil moisture content, soil structure, soil
texture, water droplet size, and organic solids. The application amount
should not exceed the available water holding capacity of the soil at the
time of irrigation nor should the plant available nitrogen applied exceed
the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is _installed to properly irrigate the acres
shown in Tables 1 and 2. Failure to apply the recommended rates and

ANIMAL WASTE UTILIZATION PLAN
amounts of nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application
rates and amounts.
I
I
I
(Application
RatelApplic. Amount
'ract l
Field I
Soil Type
I Crop
l (in/hr)
l (inches)
35 l
P3 I
NOB
l BP
l .50
I *1.0
I
35 I
I
P4 l
NOB
I
I BP
I
l .50
I
I *1.0
i
35 l
i
P5 I
NOB
I
l BP
I
l .50
I
I *1.0
I
35 l
I
-P3 I
I
I SG
I
I .5
I
l *1
I
35 I
I
-P4 I
I
I SG
I
l .5
I
l *1
I
35 i
I
--P5 l
I
l SG
I
I
I .5
I *1
I
1924 I
I
P1 I
NOB
I BP
I
l .50
l *1.0
1924
!
I P2 I
NOB
I
l BP
1
I .50
I
I *1.0
1924
I I
l --P1 I
i
I SG
I
l .5
I
*1
1924
I I
l -P2 I
I
I SG
I
l .5
l *1

ANIMAL WASTE UTILIZATION PLAN
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations, the application amount shown cannot
be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180.00 days of temporary storage and
the temporary storage must -be removed on the average of once every
6.00 months. In no instance should the volume of the waste be stored
in your structure be within the 25 year 24 hour storm storage or one
foot of freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply the
correct rates to the acres shown in Tables 1 and 2. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may
make this plan invalid.
Call your technical specialist after you receive the waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate prior to applying the waste.
NARRATIVE OF OPERATION
[IS PLAN IS WRITTEN ON AN WETTEABLE ACRE FOOTPRINT BY PULLS 1-5

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner.who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but.not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
5. Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "weather
and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be considered.
Page: 10

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to
wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right--of-ways.
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly into water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
the site.
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation.. Vegetation such as trees, shrubs., and
other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 11

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
18. If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22. Waste shall be tested within 50 days of utilization and soil
-shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when these
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be
maintained for five ( 5 ) years.
23. Dead animals will be disposed of in a manner that meets North
Carolina regulations.
Page: 12

ANIMAL WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm:RABON NURSERY 123
Owner/Manager Agreement
I (we). understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
North Carolina Division of Water Quality (NCDWQ) before the new
animals are stocked. I (we) also understand that there must be no
discharge of animal waste from this system to surface waters of the
state from a storm event less severe than the 25-year, 24-hour
storm. The approved plan will be filed on -site at the farm office
and at the office of the local Soil and Water Conservation District
and will be available for review by NCDWQ upon request.
Name of Facility Owner: MIRE RABON
(Please print)
Signature: 19Date: I2� /01
Name of Manager(If different from owner) :
Signature:
Date:
Name of Person Preparing Plan: (Please print)JOHNNY L. LANIER
Affiliation:DUPLIN SOIL AND WATER CONSERVATION DISTRICT
Phone No. 910-296-2120
Address (Agency): PO BOX 219
KENANSVILLE NC 28349
Signature: Date: 2 0/
Page: 13

G1W*iP Wdtabl� M+ :L € ::" _''`,•:' ;., k' T Om �Caj.W
4t7.-A t 4 a�i - ,•+
r1. Farm Number (Identification) . 3 1:- 9' % field Number dentification) Yiv.=
2. Irrigation System: Designation Existing Irrigation System Newl Expanded irrigation Sy teem
3. Number of Travel Lanes # Interior Lanes �_ # Exterior Lanes 22 Y eet] Length of pull(I,1)
# Interior Lanes D # Exterior Lanes SL, - (feet] Length of pull)
Interior Lanes _ 3 #Exterior Lanes 91 D [feet] Length of pull(I,3)
4. Wetted Diameter /0 [feet] From field data sheet
5. Spacing Hydrant. Spacing [feet] 9 r-d [as percent -of wetted diameter]
6. Hydrant Layout Multiple Hydrants Single Hydrant Excessively spaced Hydrants
7. Read the irrigated area per travel pull for the given wetted diameter from the appropriate table and column
based on pattern, spacing, and travel lane location.
Travel Lane Length (LI) Interior or Exterior (Lane/Hydrant)
,S i (a) Acres start end of pull from Table �70 -F Column
q! 7 (b) Acres middle portion of pull (M)
(Pull Lengt ;1,5 [feet] X Wetted Width;�,�D [feet]) / 43,560
0 (c) Acres stop end of puU from Table Column C.
2 .0 & Total acres for Travel Lane Lene h (Ll) (Sum: a + b + c)
Travel Lane Length (L?) Interior or Exterior (Lane/Hydrant)
S-1 (a) Acres start end of pull from Table E 90 Colum.-i
(b) Acres middle portion of pull (LI)
(Pull Length.. [feet] X Netted WidEh--M� [feet]} / 43,a60
O _ (c) P..res =top end of puU from Table � Coi�_�r�r _ C,
�. T oral acres for Travel Lane Length (L2) (Sum: a + b c)
Travel Lane Length (U) Interior or _3___Evterior (Lane,'Hydr?nt}
q (a) Acres start end of pull from Table t 90 F COIL'6rui
(b) Acres rdddle portion of pull (Ll)
(Pull Length 970 [feet] X Wened Width -20 flee:]) r 437560
(c) Acres stop er. nl'pull from Tableff_0_ f- ColU,1-n^
Total acres for Travel Lane Length (U) (Sum: a- b c)
S. Mul.ipiv the tabulated irrigated a_reaae value per travel puli by the nu:n'cer olf'pufis ofy category
in the
field. Sum all of these and this is the total irrigated acreage for the field.
Ej !n
(a) Acres per Travel Lane Length (L1) X = Lanes
, 0
Acres
'--1, ,) '
(b) Acres per Travel La:^;. Length (1-2) X 2 t La.-ies
= 1-4 0 9
A c r :s
(c) Acres per Travel Lane Length (L3) X ,3 m La.-ies
= L , �r �,!
Acres
Total CANVINiP Wettable Acres for field (Sum: Sa _
8b + 8c)
J,.,..,
/
Wenable Acre Computational Worksheet Completed by: z�----�- _
Date

-'' +'- � - ,z '- .,i -:�•,v;1rti+ ti :�+,:y„� ,wti�3v_-ci.•q,`-�..•,Gs'{G��1` _ �f1r-• ''�
��p N/!�s ALTS _ _ '••' •f:.l' �' .t ta."� `. i J,' ' _ -` '�:'•�T �fll�olla
i- .t, , - :y.'r.�...^,.. ryr'� Y+7 '� qwf '" �: Ne-:+rr'Ss•.
ra
�covT zero<< -.
i. Fairm Number (Identification) 3/ q field N mbe (Idert fication) 2. Irrigation System Designation Eiisting Irrigation System New/ Expanded Irrigation System
3. Number of Travel Lanes # Interior Lanes # Exterior Lanes /*16 rfeet] Length of puli(I,ij
# Interior Lanes _ # Exterior Lanes 3 afeet] Length of pull(L2)
# Interior Lanes # Exterior Lanes [feet] Length of pull(L3)
4. Wetted Diameter /0 [feet] From field data sheet
5. Spacing Hydrant Spacing [feet] 91s"-7- [as percent of wetted diatlneter]
6. Hydrant Layout Multiple Hydrants Single Hydrant Excessively spaced Hydrants
7. Read the irrigated area per travel pull for the given wetted diameter from the appropriate table and column
based on pattern, spacing, and travel lane location.
Travel Lane Length (L1) Interior or 4
L_Exterior (Lane/Hydrant)
,- Q. (a) Acres start end of pull from Table F 90 Column
/,a 1 (b) Acres middle portion of pull (L1)
(Pull Length 1 [feet] X Wetted Width -Z?[feet]) / 43,560
0 (c) Acres stop end of puU from Table 9d Column C_
Total acres for Travel Lane Length (LI.) (Sure: a + b + c)
Travel Lane Length (L2) Interior or _Exterior (Lane/Hydrant)
/ (a) Acres start end of pull from Table Column
(b) Acres muddle portion of pull (L1)
(Pull Lengtth,12, [feet] X Wetted Width /S(9 ffeet]) 143,560
b _ (c).A.;res -top end of pull from 7able L 90 f Cols mr
Total acres for Travel Lane Length (L2) (Sum: a + b . c)
Travel Lane Length (L3) Inte or or Exterior (Lane;"Hydrant)
(a) Acres start end of pull from Table Colum-1
(b) Acres middle portion of pull (LI).
(Pull Length (feet] X Weaed WI',-h ff e:]) / 43,560
(c) Acres stop end of pull from Table Column
Total acres for Travel Lane Length (Li) (Sum: a ; b + c)
�lr tabula -Led da .-a7e value e-travel 't ?- 11• eg• the
S. _.fG,�ip�c the tabu t d i:ii�_ted acr.�.�„ � lt. per pl-ti b til,. n;:ml � of'pulls of ea�i�l cat..�o.-y in
geld. Sum all of these and th:s is the total irrigated acreage for the field.
Jr0 (a) Acres per Travel Large Length (LI) X L = Lanes kcres
l S_ ?__ (b) Acres per Travel Large Length (L2) X SJ r Lanes - /� �vL Acres
(c) Acres per Travel Lane Length (U) X rr Lanes - Acres
? `r- Total CAWIMP Wettable Acres for field (Sum: Sa _ Sb + Sc)
Wettable Acre Computational Work -sheet Completed by! } Date: �
u

WETTABLE ACRES
IRRIGATION SYSTEM DESIGN PARMATERS
and
COMPUTATIONAL WORKSHEET SUMMARY
Landowner 1 Operator Name Mike Rabon
Adress . 446 NC 50 & US 117
Warsaw NC 28398
Telephone [phone]
TABLE 1 - Field Specifications
County Du lin
Date 2121101
Facility # 31-297
Tract
Number
Hydrant
or
field (1)
Number
acres
start end
welted
area
acres
middle
wetted
area
acres
stop end
welted
area
Approximate
Maxlmun
Useable Size
of field (2)
(acres)
Table
column
length
of
pub
In feet
Width
of
pulls
In feet
Sall T
Slope
%
crop(s)(
Maximun
Application
Rate (3)
INh
Mwdumn
Application
per irrigation
cycle (3)
inches
71924
21
0.59
1.47
0
2.06
E90+
B-C
225
280
NOS
0-5
bermuda / small oin
0.5
1
71924
0.69
3.5
0
4.09
E90+
B-C
535
280
NOS
0-5
bermude / jMg_praIn
0.5
1
435
P3
o.59
8.35
0
6.94
Ego+
B-C
970
280
NOB
"
barmuda / small grain
0.5
1
435
p4
0.59
1.21
0
1.8
E90+
B-C
185
280
NOB
0-5
bermuda / small grain
0.5
1
435
0.16
1.52
0
1.52
E90+
B-C
395
150
NOB
0.5
bennuda / small on
0.5
1
1 see attached map.
2 Total held acreage minus required buffer areas.
3 Refer to N.C. Irrigation guide, Field Office Technical Guide, Section II G. Annual applicallon must root exceed the agronomic rates for the soil and crop used,
Wettable Acre Computational Worksheet Completed by: Johnn Lanier Date a.l 0 J

State of North Carolina
Department of Environment
and Natural Resources
Michael F. Easley, Governor
William G. Ross Jr., Secretary
Kerr T. Stevens, Director
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Mike Rabon
Rabon Nursery 1, 2 & 3
446 NC 50 & US 117
Warsaw NC 28398
Dear Mike Rabon:
g ffl�!W'j
k,
:DENR
NORTH CAROLINA DEPARTMENT Or
ENVIRONMENT AND NATURAL RESOURCES
February 5, 2001
Subject: Notification for Wettable Acre Determination
Animal Waste Management System
Rabon Nursery 1, 2 & 3
Facility Number 31-297
Duplin County
A letter dated January 15, 1999 was sent to advise you about concerns associated with Certified Animal
Waste Management Plans and the method by which the irrigated acres within the plans were calculated. Only
the acres that are wetted can be credited in the waste management plan as receiving waste application. Any
acreage within the plan that can not be reached by waste application equipment can not be used as part of your
plan.
An evaluation by Dean Hunkele on 7/20/99 was made to review the actual number of acres at your
facility that receive animal waste during land application. The evaluation of your facility has yielded one of
the following two results as indicated by the box marked with an "Y'.
Category 1:
❑ The evaluation of your facility could not be completed due to a lack of information. Please
contact your Technical Specialist to assist in providing Dean Hunkele the necessary
information to potentially exempt your facility from undergoing a complete wettable acre
determination. Please submit this information to Dean Hunkele, at 127 Cardinal Drive
Extension, Wilmington, NC 28405-3845, within in 90 days of the receipt of this letter. If you
have any questions please contact Dean Hunkele at [phone]. If within 90 days you
are unable to provide Dean Hunkele with the information you are automatically
required to complete a Wettable Acre Determination as described by Category 2
below, within 180 days of receipt of this letter.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled110% post -consumer paper

Notification for Wettable Acre Determination
Animal Waste Management System
Page 2
Category 2:
Your facility has been identified by the Department of Environment and Natural Resources
as a facility that may have overestimated the number of acres actually receiving animal
waste. Therefore, some or all of your fields may be exceeding the allowable loading rates
set in your Certified Animal Waste Management Plan.
In order to resolve this issue, please contact a designated Technical -Specialist to -have -him -
or her conduct a Wettable Acre Determination for your facility. The Technical Specialist must
be one that has been approved by the Soil and Water Conservation Commission to conduct
Wettable Acre Determinations. Many Technical Specialist with the N.C. Cooperative Extension
Service, the Soil and Water Conservation Districts, the Natural Resources Conservation
Service, and the Division of Soil and Water Conservation have received this special
designation. You may also contact a private Technical Specialist who has received this
designation, or a Professional Engineer.
All needed modifications to your Animal Waste Management System must be made and
the Wettable Acres Determination Certification must be returned to DWO within the next
180 days. If the needed modifications are not made and if the form is not returned within the
required time, DWO will be forced to take appropriate enforcement actions to bring this facility
into compliance. These actions may include civil penalty assessments, permit revocation,
and/or injunctive relief.
Once a Wettable Acre Determination has been completed, a copy of the attached Wettable
Acre Determination Certification must be submitted to the address listed on the form. Please
note that both the owner and the Technical Specialist must sign the certification. A copy of all
the Wettable Acre Determination documentation that applies to your Waste Utilization Plan
must be kept at your facility. DWO and the Division of Soil & Water Conservation Staff will
review all documentation during their annual visit of your facility. An additional copy must by
kept on file at the local Soil & Water Conservation District Office. Please note that if you install
or modify your irrigation system, a designated Irrigation Specialist or a Professional Engineer
must also sign the Wettable Acre Determination Certification.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Sonya Avant of our
Central Office staff at [phone] ext. 571.
t Sincerely,
Kerr T. Stevens
cc: Wilmington Regional Office
Duplin County Soil and Water Conservation District
Facility File
Murphy Family Farms

h
State of North Carolina
Department of Environment
and Natural Resources
'1 Division of Water Quality
�! James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
Rabon Nursery 1, 2 & 3
446 NC 50 & US 117
Warsaw NC 28398
Attn: Mike Rabon
Dear Mike Rabon:
APR 1 0 2000
Old
December 10, 1999
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject; Certificate of Coverage No. AWS310297
Rabon Nursery 1, 2 & 3
Swine Waste Collection, Treatment,
Storage and Application System
Duplin County
In accordance with your application received on June 10, 1999, we are forwarding this Certificate of
Coverage (COC) issued to Mike Rabon, authorizing the operation of the subject animal waste collection,
treatment, storage and land application system in accordance with General Permit AWG100000. This
approval shall consist of the operation of this system including, but not limited to, the management of
animal waste from the Rabon Nursery 1, 2 & 3, located in Duplin County, with an animal capacity of no
greater than 7800 Wean to Feeder and the application to land as specified in the Certified Animal Waste
Management Plan (CAWMP).
The facility's CAWMP meets all requirements in place at the time of certification. However, it appears
that the irrigation system on site may not adequately cover all acreage listed in the Waste Utilization
Plan. The owner should address this inconsistency as soon as possible.
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAW 4P may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
1617 Mail Service Center, Raleigh, NC 27699-1617 -telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Certificate of Coverage AWS310297
RabonNursery -1, 2 of 3
Page 2
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This request
shall be made within 30 days of notification by the Division. - --
�"v
This COC is not automatically transferable. A name/ownership change application must be submitted to
the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual non -discharge permit by contacting the engineer listed below for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
The subject farm is located in the Wilmington Regional Office. The Regional Office Water -Quality Staff
may be reached at [phone]. If you need additional information concerning this COC or the
General Permit, please contact Dianne Thomas at [phone] ext. 364.
Sincerely,
Kerr T. Stevens
cc: (Certificate of Coverage only for all cc's)
Duplin County Health Department
Wilmington Regional Office, Water Quality Section
Duplin County Soil and Water Conservation District
Permit File
� ME-B- NIes$

r cl~
State of North Carolina
Department of Environment and Natural Resources JUN f 0 i ;
j Division of Water Quality Al
on-Disc" Permit Application Form �' D1,cnarga
(THIS FORM MA Y BE PHOTOCOPIED FOR USE AS AN ORIGINAL)
General Permit - Existing Animal Waste Operations
The following questions have been completed utilizing information on file with the Division. Please
review the information for completeness and make any corrections that are appropriate. If a
question has not been completed by the Division, please Complete as best as possible. Do not leave
any question unanswered.
1. GENERAL INFORMATION:
1.1 Facility Name: Rabon Nursery 1 2 & 3
1.2 Print Land Owner's name: Mike Rabon
1.3 Mailing address: 446 NC 50 & US 117
City, State: Warsaw NC Zip: 28398
Telephone Number (include area code): 910-293-7660
1.4 County where facility is located: _Duplin _ ____
1.5 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a
copy of a county road map with the location of the farm identified): Nursery #1 is on north side of SRI344, approximately
0.5 miles west of intersection with Hwy 50. Nursery #2 and #3 are at end of SR1344,
1.6 Print Farm Manager's name (if different from Land Owner):
1.7 Lessee's / Integrator's name (if applicable; please circle which type is listed): Murphy Family Farms
1.8 Date Facility Originally Began Operation:
1.9 Date(s) of Facility Expansion(s) (if applicable):
f►��]��,7_:11_Y_1;1��� Iw;11Cf17�/�I liL���
2.1 Facility No.: 31 (county number); 297 (facility number).
2.2 Operation Description. Swine operation
Wean to Feeder
7800- Certified Design Capacity
Is the above information correct? Qyes; [�:]no. If no, correct below using the design capacity of the facility
The "No. of Animals" should be the maximum number for which the waste management structures were designed.
Type of Swine
• Wean to Feeder
• Feeder to Finish
• Farrow to Wean (# sow)
• Farrow to Feeder (# sow)
• Farrow to Finish (# sow)
No. of Animals Type of Poulgy No. of Animals
Other Type of Livestock on the farm:
• Layer
• Non -Layer
• Turkey
Type of Cattle No. of Animals
• Dairy
• Beef
No. of Animals:
FORM: AWO-G-E 5/28/98 Page 1 of 4 31 - 297

'i)
2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): _ 16.00 : Required Acreage (as listed in the AWMP): 9.6
- 2.4 Number of lagoons/ storage ponds (circle which is applicable): 3
. 2.5 Are subsurface drains present within 100' of any of the application fields? YES or (please circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES or NO (please circle one)
'�'2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, N andards, etc.) (Swine Only)
YES r NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited? Vdl , I -1�S l , .s
What was the date that this facility's land application areas were sited?
Tj
3. REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
AvOicants Initials
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit
application for animal waste operations.
The CAWMP must include the following components. Some of these components may not
have been required at the time the facility was certified but should be added to the
CAWMP for permitting purposes:
3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application.
3.3.4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application field.
3.3.8 The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.3.10 A site schematic.
3.3.11 Emergency Action Plan.
3.3.12 Insect Control Checklist with chosen best management practices noted.
3.3.13 Odor Control Checklist with chosen best management practices noted.
3.3.14 Mortality Control Checklist with the selected method noted.
3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility.
3.3.16 Operation and Maintenance Plan.
If your CAWMP includes any components not shown on this list, please include the
additional components with your submittal.
FORM: AWO-G-E 5/28/98
Page 2 of 4 31- 297

Facility Number: 31 - 297
Facility Name: Rabon Nursery 1, 2 & 3
r �
4. APPLICANT'S CERTIFICATION:
rRIiECEI1/El)
lft.A7i *,,, ,,.' P' 'EcnON
,.iUINJ .{ 0 fJ�
Non-0ischcT3 PXMif'ung
I, M► VN,9— Ka—bz) t1 _ (Land Owner's name listed in question 1.2), attest that
this application for '} (Facility name listed in question 1. 1)
has been reviewed by me and is accurate and complete to th$best of my knowledge. I understand that if all required parts of this
application are not completed and that if
all
required supporting information and attachments are not included, this application
package will be returned to me as inc p�npiet�'�.1J311.� Signature -K _ y y_�Aj6~,J_ Date _
5. MANAGER'S CERTIFICATION: (complete only if different from the Land Owner)
1, (Manager's name listed in question 1.6), attest that this
application for (Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned as incomplete.
Signature Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
FORM: AWO-G-E 5/28/98 Page 3 of 4 31- 297

DIVISION OF WATER QUALITY REGIONAL OFFICES (1I98)
tr
Asheville Regional WQ Supervisor
59 Woodfin Place
Asheville, NC 28901
[phone]
Fax [phone]
Avery Macon
Buncombe Madison
Burke
McDowell
Caldwell
Mitchell
Cherokee
Polk
Clay
Rutherford
Graham
Swain
Haywood
Transylvania
Henderson
Yancey
Jackson
Fayetteville Regional WQ Supervisor
Wachovia Building, Suite 714
Fayetteville, NC 28301
[phone]
Fax [phone]
Washington Regional WQ Supemisor
943 Washington Square Mall
Washington, NC 27889
(919) 94&" 1
Fax [phone]
Beaufort
Jones
Bertie
Camden
Lenoir
Chowan
Martin
Pamlico
Craven
Pasquotank
Currituck
Paquimans
Dare
Pitt
Gates
Tyrell
Greene
Washington
Hertford
Wayne
Hyde
Mooresville Regional WQ Supervisor
919 North Main Street
Mooresville, NC 28115
[phone]
Fax [phone]
Raleigh Regional WQ Supervisor
-NM Barrett Dr.
Raleigh, NC 27611
[phone]
Fax [phone]
Chatham
Nash
Durham
Edgecombe
Northampton
Orange
Franklin
person
Granville
Vance
Halifax
Wake .... .
Johnston
Warren
Lee
Wilson
Wilmington Region. WQ Supervisor
127 Cardinal Drive Extension
Wilmington, NC 28405-3845
[phone]
Fax [phone]
Anson
Moore
Alexander
Lincoln Brunswick New Hanover
Bladen
Richmond
Cabarrus
Mecklenburg Carteret Clnslow
Cumberland
Robeson
Catawba
Rowan Columbus Pender
Harnett
Sampson
Cleveland
Stanly Duplin
Hoke
Scotland
Gaston
Union
Montgomery
Irode l
Winston-Salem Regional WQ Supervisor
585 Waughtown Street
Winston-Salem, NC 27107
(910) 77146W
Fax (9I0) 771- 631
ALamance Rockingham
Alleghany Randolph
Ashe
Stokes
Caswell
Surry
Davidson
Watauga
Davie
Wilkes
Forsyth
Yadkin
Guilford
FORM: AWO-G-E 5/28/998 Page 4 of 4

I _ N
State of North Carolina fit, ri �C 1; ! I� E. ID
of Environment and Natural Resources p�`^'�
_ Division of Water Quality Q <.
Non -Discharge Permit Application Form f���
(THIS FORM MAY BE PHOTOCOPIED FOR USE AS AN ORIGINAL) 1vOl1-Disc ai-gs Parmix 9
General Permit - Existing Animal Waste Operations
The following questions have been completed utilizing information on file with the Division. Please
review the information for completeness and make any corrections that are appropriate. If a
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
1. GENERAL INFORMATION:
1.I Facility Name: Rabon Nursery_ I, 2 & 3_
1.2 Print Land Owner's name: Mike Rabon
1.3 Mailing address: 446 NC 50 & US 117
City, State: Warsaw NC Zip: 28398
Telephone Number (include area code): 910-293-7660
1.4 County where facility is located: Duphn
I.5 Facility Location (Directions from nearest major bighway. Please include SR numbers for state roads. Please include a
copy of a county road map with the location of the farm identified): Nursery #1 is on north side of SR1344, approximately
0.5 miles west of intersection with Hwy_50. Nursery #2_and _#3 are at end of SR1344.
1.6 Print Farm Managers name (if different from Land Owner):
1.7 Lessee's / Integrator's name (if applicable; please circle which type is listed). Murphy Family Farms .
1.8 Date Facility Originally Began Operation: 01/01/91
1.9 Date(s) of Facility Expansion(s) (if applicable):
2. OPERATION INFORMATION:
2.1 Facility No.: 31 (county number); 297 (facility number).
2.2 Operation Description: Swine operation
Wean to Feeder
7800- Certified Design Capacity
Is the above information correct? Oyes; Ono. If no, correct below using the design capacity of the facility
The "No. of Animals" should be the maximum number for which the waste management structures were designed.
Tvtse of Swine
• Wean to Feeder
• Feeder to Finish
• Farrow to Wean (# sow)
• Farrow to Feeder (# sow)
• Farrow to Finish (# sow)
No. of Animals Type of Poultry No. of Animals
Other Type of Livestock on the farm:
• Layer
• Non -Layer
• Turkey
Type of Cattle No. of Animals -
• Dairy
• Beef
No. of Animals:
FORM: AWO-G-E 5/28/98 Page 1 of 4 31 - 297

2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): 16.00 Required Acreage (as listed in the AWMP): 9.6
- 2.4 Number of Iagoons/ storage ponds (circle which is applicable): 3
2.5 Are subsurface drains present within 100' of any of the application fields? YES or (please circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES or NO (please circle one)
�2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, andards, etc.) (Swine Only)
YES r NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited?
What was the date that this facility's land application areas were sited? q
3. REQUIRED IT1EM_S CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
AEmlicants Initials
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit
application for animal waste operations.
The CAWMP must include the following components. Some of these components may not
have been required at the time the facility was certified but should be added to the
CAWMP for permitting purposes:
33.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application.
3.3.4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application f eld_
3.3.8 The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.3.10 A site schematic.
3.3.11 Emergency Action Plan.
3.3.12 Insect Control Checklist with chosen best management practices noted.
3.3.13 Odor Control Checklist with chosen best management practices noted.
3.3.14 Mortality Control Checklist with the selected method noted.
3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility.
3.3.16 Operation and Maintenance Plan.
If your CAWMP includes any components not shown on this list, please include the
additional components with your submittal.
FORM: AWO-G-E 5/28/98 Page 2 of 4 31 - 297

Facility Number: 31 - 297
Facility Name: Rabon Nursery 1, 2 & 3
4. APPLICANT'S CERTIFICATION:
WAT-
Alton-Discnar93 PaimitGng
k V\V-- _ K0.bz) (Land Owner's name listed in question 1.2), attest that
this application for - &k C1_ _ . _� \y�.CS��� _ _'t" (Facility name listed in question 1,1)
has been reviewed by me and is accurate and complete to thdbest of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be Ieturned to me as incp�rtpiete.
Si -mature C ,LY�lef 6� Date
5. MANAGER'S CERTIFICATION: (complete only if different from the Land Owner)
1, (Manager's name listed in question 1.6), attest that this
application for (Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned as incomplete.
Signature Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
FORM: AWO-G-E 5/28/98
Page 3 of 4 31- 297

DIVISION OF WATER QUALITY REGIONAL OFFICES (1/98)
Asheville Regional WQ Supervisor
59 Woodfin Place
AshevUe, NC 28801
[phone]
Fax [phone]
Avery Macon
Buncombe Madison
Burke
McDowell
Caldwell
Mitchell
Clyerokee
Polk
Clay
Rutherford
Graham
Swain
Haywood
Transylvania
Henderson
Yancey
Jackson
Fayetteville Regional WQ Supervisor
Wachovia Building, Suite 714
Fayettwille, NC 28301
[phone]
Fax [phone]
RVashington Regional WQ Supavisor
943 Washington Square Mall.
Washington, NC 27989
[phone]
Fax [phone]
Beaufort
Janes
Bertie
Camden
Lenoir
Chowan
Martin
Pamlico
Craven
Pasquotaak
Currituck
Pergairftans
Dare
Pitt
Gates
Tyrell
Greene
Washington
Hertford
Wayne
Hyde
Mooresville Regional WQ supervisor
919 North Main Street
Mooresville, NC 28115
[phone]
Fax [phone]
Raleigh Regional WQ Supervisor
38M Barrett Dr.
Raleigh, NC 27611
[phone]
Fax [phone]
Chatham
Nash
Durham
Northampton
Edgecambe
Orange
Franklin
Person
Granville
Vance
Halifax
Wake ...
Jobmmn
Warren
Lec
Wilson
Wilmington Region. WQ Supervisor
127 Cardinal Drive Extension
Wilmington, NC 28405-3845
[phone]
Fax [phone]
Anson
Moore
Alexander
Lincoln Brunswick New Hanover
Bladen
Richmond
Cabarrus
Mecklenburg Carteret Onslow
Cumberland
Robeson
Catawba
Rowan Columbus Pender
Harnett
Sampson
Cleveland
Stanly Duplin
Hoke
Scotland
Gaston
Union
Montgomery
hvdeil
Winston-Salem Regional WQ Supervisor
585 Waughtown Street
Winston-Salem, NC 27107
[phone]
Fax [phone]
Alamance Rockingham
Alleghany Randolph
Ashe
Stokes
Caswell
Surry
Davidson
Watauga
Davie
Wilkes
Forsyth
Yadkin
Guilford
FORM: AWO-G-E 5/28/98 Page 4 of 4

DVS V

2.3 Acreage cleared and available for application (excluding all required buffers and areas rno covered.by:tbe application
system): 16.00 :Required Acreage (as listed in the AWMP):� 9.6
- 2.4 Number of lagoons/ storage ponds (circle which is appli
-jk� 2.5 Are subsurface drains present within 100' of any of the
2.6 Are subsurface drains present in the vicinity or under tJ
:�V.7 Does this facility meet all applicable siting requiremen
What was the date that this facility's swine houses and
What was the date that this facility's land application a
pplication fields? YES or NO (please circle O�
lagoon(s)? YES or (please circle on
? (Swine Farm Siting Act, NR S Standards, etc.) (Swine Only)
YES or NO (please circle on,
3. ITEMS CHECKLIST 1
Please indicate that you have included the following required i
item.
were sited?
were sited?
space provided next to each
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
33 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit
application for animal waste operations.
The CAWMP must include the following components. Some of these components may. not
have been. required at the time the facility was certified but should be added to the
CAWMP for permitting purposes:
3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc_)
3.3.3 A map of every field used for land application.
3.3.4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PA_N applied to every land application field.
33.8 The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.3.10 A site schematic.
3.3.11 Emergency Action Plan.
3.3.12 Insect Control Checklist with chosen best management practices noted.
3.3.13 Odor Control Checklist with chosen best management practices noted.
3.3.14 Mortality Control Checklist with the selected method noted.
3.3.15 Lapoon/storage pond capacity documentation (design, calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility.
3.3.16 Operation and Maintenance Plan.
If your CAWMP includes any components not shown on this list, please include the
additional components with your submittal.
ApiDlicants Initials
"._6L ;
FORM: ANVO-G-E 5/28/98 Page 2 of 4 31 - 297

Swine.Farm Waste Management Odor Control Checklist
Source Cause I;iVII's to Minimize Oiler site specific Practices -
Farmstead Swine prodiiclion Vegetative or wooded bufrcrs — -
fq Recommended Kest management practices
V Good judgment and common sense
Animal body Dirty manure -covered Dry floors
surfaces animals
Floor surfaces Wet manure -covered floors Slotted floors
Or Waterers located over slotted floors
Cl Feeders at high end of solid floors
13 Scrape manure buildup from floors
fel Underfloor ventilation for drying
Manure collection • Urine V Frequent rnanure removal by flush, pit recharge,
pits . Partial microbial /or scrape
decomposition 9 Underfloor ventilation
Ventilation exhaust • Volatile gases t—V Fan maintenance
rafts • Dust [R Efficient air movement
Indoor surfaces • Dust Waslidown hethveen groups of animals
Flush tanks • Agitation of recycled lagoon
liquid while tanks are filling
Feed additives
Vr
ceder covers
ccd delivery downspout extenders to recder
covers .
n Flush tank covers
O Extend fill lines to near bottom ortanks wills
Anti -siphon vents
Mush alleys • Agitation during wastewater Underfloor flush with underfloor ventilation
conveyance

Swint: Farm Waste Management Odor Control Checklist
Source Cause HMI's to Minimize Odor Site Specific Practices
Pit recharge points + Agitation of recycled lagoon 0 Exlend recharge lines to near Imltom of pits with
liquid while pits are filling anti -siphon vents
Lift stations + Agitation during sump tank 0 Sump tank covers
filling and drawdown
Outside drain . Agitation during wastewater 0 Box covers
collection or junction conveyance
boxes
End of drainpipes + Agitation during wastewater 0 Extend discharge point of pipes underneath
at lagoon conveyance lagoon liquid level
Lagoon surfaces + Volatile gas emissions Proper lagoon liquid capacity
+ Biological mixing Correct lagoon startup procedures
+ Agitation Minimum surface area -to -volume ratio
0 Minimum agitation when pumping
171 Mechanical aeration
Cy Proven biological additives
Irrigation sprinkler + High pressure agitation a Irrigate on dry days with little or no wind
nozzles + Wind drift l 'Minimum recommended operating pressure
GrIPump intake near lagoon liquid surface
CI Pump from second -stage lagoon
Storage tank or + Partial microbial 0 Bottom or midlevel loading
basin surface decomposition D Tank covers
+ Mixing while filling 0 Basin surface mats of solids
Agitation when emptying 0 Proven biological additives or oxidants

Swine Farm Waste Management Odor Control Checklist
Source Cause IIMI's to Minimize Odor Site Specific Practices
Settling basin surface . Partial microbial ❑ Extend drainpipe outlets underneath liquid level
decomposition Cl Remove settled solids regularly
• � Mixing while filling
• Agitation when emptying
Manure, slurry, or . Agitation when spreading Cl Soil injection of slurry/sludges
sludge spreader . Volatile gas emissions 0 Wash residual manure from spreader alter use
outlets 17 Proven biological additives or oxidants
Uncovered manure, • Volatile gas eertissions while 0 Soil injection of slurry/sludges
slurry, or sludge on drying ❑ Soil incorporation within 48 hours
field surfaces 0 Spread in thin uniform layers for rapid drying
CI Provcn biological additives or oxidants
Dead animals • Carcass decomposition Proper disposition of carcasses
Dead animal disposal . Carcass decomposition ❑ Complete covering of carcasses in burial pits
pits Cl Proper location1construction of disposal pits
Incinerators • Incomplete combustion ❑ Secondary stack burners
Standing water • Improper drainage 21 Grade and landscape such that water drains away
around facilities . ]Microbial decomposition of from facilities
organic matter
Manure tracked onto . Poorly maintained access farm access road maintenance
public roads from roads
farm access
Additional Inforniation: Available From:
Swine Manure Management; .0200 Rule/BIVIP Packet NCSU, County Extension Center

Swine Production Farm Potential Odor Sources and Remedies; EBAE Fact Shect
Swine Production Facility Manure Management: Pit Rechargc—Lagoon Treatment; EBAE 128-88
Swine Production Facility Manure Management: Underfloor Flush —Lagoon Treatment; EBAE 129-88
Lagoon Design and Management for Livestock Manure Treatment and Storage; EBAE 103-83
Calibration of Manure and Wastewater Application Equipment; EBAE Fact Shect
Controlling Odors from Swine Buildings; PIT-1-33
Environmental Assurance Program; NPPC Manual
Options for Managing Odor; a report from the Swine Odor Task Force
Nuisance Concerns in Animal Manure Management: Odors and Flies; PRO107, 1995 Conference
Proceedings
NCSU—BAE
NCSU—BAE
NCSU—BAE
NCSU BAE
NCSU---BAE
NCSU—Swine Extension
N.C. Pork Producers Assoc.
NCSU Agricultural Communication
Flcirida Cooperative Extension f

Insect Control Checklist for Animal Operations
Source Callse I11VII's (o Cul)(1-ol lusecls Site Specific Practices
Deed storage Accumulations of feed Reduce moisture accumulation within and around
residues immediate perimeter of feed storage arras by
ensuring drainage is away from site and/or
providing attenuate containment (e.g., covered bill
for brewer's grain alld su1111ar high moisture grails
1)1'0Cd llCtS)
0 Inspect for and remove or break up accumulated
solids in filter strips around feed storage as needed
Arlinlal holding • Accumulations of Animal . 0 Lfilllillate low al-Cas that Imp moisture 111011g rel)CCS
areas wasles and feed wastage and other locatlons where waste accumulates and
disturbance by anlillalS is minimal
'dry manure Accumulations of animal
Illildling sys(eills wasles
Cl Maintain fence rows and filler strips around animal
holding areas to minimize accumulations of wastes
(i.e., inspect for and remove or break up
accumulated solids as needed)
O Renlovc spillage on a routine hasis (e.g.,
7- to I0-day inlerval during stammer; 15- to 30-clay
interval during winter) where manure is loaded for
land 11)111ica(ion or disposal
• Provide 161' adequate draiilage al-oulld 111 Illu'e
stockpiles
0 IIISI)CCI 101' i111d W1110VC Or I11'C lk ul) acelllnulatcd
wasles ill III(Cr S11-il)s around slockpiles and manure
u• MUM illror11111liull cont:lct:
handling areas as needed

Insect Control Checklist for Animal Operations
Source Cause I31Vil's to Control Insects Site Specific Practices
Liquid Systems
Flush gutters Accuillulation of solids lEr Flusk system is designed and operated
sufficiently to remove accumulated solids from
gulters as designed
Remove bridging of accumulated solids at
discharge
Lagoons and pits • Crusted solids Maintain lagoons, settling basins and pits -where
pest breeding is apparent to minimize the crusting
ofsolids to a depth of no more than 6 to 8 inches
,pver more than 30 percent of surface
.xcessive vegetative • Decaying vegetation p' Maintain vegetative control along banks of
,vowlll lagoons and other impoundments to prevent.
aecumulatiori of decrying vegetative matter along;
water's edge on irnglotlnthrlent's perimeter.
Dry Syslenls
ceders Deed spillage 9 Design, oper•ate, and rllarntain Iced Syslenls
(e.g., bunkers and troughs) to minimize the
/accunlulation of decaying wastage
M Clean up spillage on a rentlne basis (e.g;., 7- to 10-
day interval dlrring summer; 45- to 30-day interval
during winter)

-� Mort.aIity lanagement Methods
(check which method(s) are being implemented)
❑ Burial three feet beneath the surface of the ground within 24 hours after
knowledge of the death. The burial must be at least 300 feet from any flowing
stream or public body of water.
• Rendering at a rendering plant Iicensed under G.S. 106-168.7
❑ Complete incineration
❑ In the case of dead poultry only, placing in a disposal pit of a size and design
approved by the Depanment of Agriculture
Ct Any method which in the professional opinion of the State Veterinarian would
make possible the salvage of part of a dead animal's value without endangering
human or animal health. ff-ritten approval of the State Veterinarian must be
attached)
December 18, 1996

�� ;lx.� 'ws-i � � �r,'. s .-• � •^j ,±}, 'R �-, �sf,ni � syll`w
t6 � x .fi +1 tii 3i s�4d ,J1.1 f tV ' {rt cw
i r ,.4�1:�'1 •'- 1 `:'Y,•.�."". 1 5 t r'' 4 ' s
L iSY +'���-, ;�; .�1," , .�� '�� s[��,, -+ � , *,,;^l.^tJ' � +r, • i - V q i �'��
yr I+Sp,� r - '� ,c +, '' it ,w•C.ri. � ,. wa ,_ t � 1 44.. #r3
r Y .M ' „j' - j t ,+w �'I. �ti� jji��i,'H*M `7i � +►�S.R��.{'/�'�, ,V t Y
' K'. 1 i •-• "•i _ n����r � �fi f r l ! . '�};iYy ,-// 1 f s �• Y`
r. - � g4 � ..• fiY f"'`r'i'+'�+F � ,.! )/ � ' Ij.r—.1 � .4y., - �[{
r LY c n. tr � � ; + 1 _�7f,. r ' a;' (j j ! r yT�i+ ' I � "r.•�;; Li) � ri �
' � +.{� ,��x�J 1 A a�A.w s )� 7' ,'.",(y f .+ •,: � �,.•. �: v... I..s -1+ y � l t"y � '', i •+ -+
..I ` lJ
A cIN
' i+, + !.K` 'r • +65
��f$ V i ,+ y ti` �`• %' '..+ � ` 3' � x i>�r,R 'S •V'•' 7 .r� -� 4,� � �, ';, ! r d �1
`f--:i� Ei'�r I'• ,'Jtit r-,I` �_ !` �... II S� nx 1r'�S P, Q
�� �•d��� i� .t'1 _ter ss,e..:, u�-";I r c�. 3�i kk'�.i�=5ry Y.s. -. rr-..•.^f'; - "..- �^
`cr
4L €� Il _,'1•�� > 1. ,- <jy �' ' '. � �. t t*"
•�,L �:. 'i} .; rr� L� vy /� `' :I'^„�` i_ �:M� rl s•`+
t: I ��� .�.. �1; -: 1 ... ,i5 ,� " •k r��/\• . 1� f i i I ti a �y�t�: �:r :f. � �
5.. }.... ,pv.`°'+"�., �1 ll "� '�� ii•V +l1"s `\ `
7.
NN I
1 �• .� 4 1 " i �y'.. +r1 a= .S) .Q J �r+r P r�i fl. �`•, `f i l q 1J`�
! dry _' �', i �� ; J"/♦♦ , t7 R 1 '�1a: ty 3F� ,�"' i r" n ji S' ,I;J M 1 Q\I �j T}
• i .,s � ! .� ' i + +I ` � fI'— r � r ti. . � S 't],�"� � r'k.� � �' a l �` f'"! �..: T�
� -+ �� iJl) �'` � -� k9 5 �"t ♦ �\ t .. � � � '\* �Ssy �' � "'"'fir r I .r' � � ...:..�.. ...
\ r+S-;s.,\ �' h t1�,r29+"
1F7
:.,.. � --• •— —� �"'r.• �' _. {� � � �.rtr���. � J � th t j���;i I a d ,�rf?'i,'" .tom F"15 i ± j ;�
^'. - - � f +Ew�1 +tales d r -+A• .+ 4
�` •ray ..+ry /%„ :,�'��` _ y��r �« ��.( ,� � v A 1 1' dk17' r ,.r J-xS y ,r+w S+'_ a}� s• .n - i.
` I /r, l�� ! •'•� r` - ��� y ' i n��>�. I �� �7�''/ 1ri � �, „� 5 I '. 1 + 4 JE l � ` L'KY^ 1;i. d, I� S )L 1. � -. .
,• � � 1-, y.�l �s„ Q �� ' �k,, it "+ C",�1 ay 11�4� + r Fad, '� i•' Y r ,. s� , W-
� tt: �t+`� t i O r .� ``♦<'�r " , t ��y,i�• rye, fi." ,�. !"'t I� � '+ �' C` - ,,ta�,`'.
, � � - � �:, �. e I`. -�_ti r 5 -J 1 ! + I'ti`�!! i + f r.r� � �. ���"%'/��\ /�+� �y'lltyf..--•at �'
�-�•p'f" 1. ,rr..��, �,,r•'r L
1l1� .. {, Y{�• r�j;7 ASS• -� l I��51 {S ram'/ t\\ '"f '1r'7a ) r � 1
rAo 1Sj f� 'I k "r �—J Id it;jf,Y r C' \ d �F
_tl x� ,
or
TWO
o - `Jr 1 '. Mon �`:Q _. rl ' � � {1 � \ .\ ��. t N' .,! V t�
ii1sgilH' !�°Y��' j ! ! l • "��� � ,� �,i wzY^ n1yi� l •` � '^'� �\�' a ,.g � �; `\,'� _ t i�.i ` h'� f -v, ..
r1F �t!•`r-' � � � !1 Cs '0+ y�n ' n!>•'r•i..s >•r •"rkw.' ''� � �.. m Ni \� \_ S 7�i �i !3 �=t 1ti
%T wr'� �• " � 1 `� -�v '}•rt': �'TRr 4
,:�'1q'%A"}V
_tip ti \ d CI �\� f +•. � .? ..
a' ♦y , r r{I
� `.\ � I cj 11 � ir,•� ���k9;�.Y7;1 r,. i.3 �. � CV)
'��� .a+t �� �ir�\� �• r `:<., ^''�`• r} �� d �,C ":?'� "��'�� � t,i }. y!yy�' ., .a'iM `�°. { \�.✓ k� a? liT� rk �k rVyr "' ,,Y'>, .`�fy,
f .r Y r �� \ ra ��'� •l •• i > / f ♦ 1 3,y9 3 1 '���.. �.
I + �� � 1lf, N .iiv �S+ T \ { / /�� 1 ' ;Yi •� ,i.� >�, `' mot• r+ �. 4' t _ J � ••��� is l , '� ?., V-" " n .�1 ,� * i
1 syt .s wY,w � 1' \ f F y * r "' h ��Itt4aa ;• ` �` �' �' %_lqI
�.t F,i/c6 :i y♦lr� fir, �{'� ��# }� "Cba
AP
/� \:s1� �'•'r. .r i t �'i':'• �i,gi Jt':�, / I` r L y'iF gin: :i z r tVY:
A� \ II t"y - Aviv.'''�;'i�. ' �'y:, '� �� "f5.}..5 \ 1 ✓• S *-J \ ! I ,+.' ^,�J r 3 e
hk fir! , , s ytl
Ip',, �++� i f o?`. �y�, \ �e� s}'rr'\ ,'1♦ fid }'r v7 2'krr# �' M� �.
+� also.
ss++
+�a: : r1�!.: \ I rk -.h •1 �? '' I I 't -+ . r ,}` '7 A ,'/ .�i `4� ✓ ,,'%' s` ,r--- t.. a." 'Vi ,i .ks �, '•
1• +' f -_ �r �Y.r � e r. � aj �i,{ !-.� I #Irt, j 7 'ray �pt,� kt
q•( h. iy. Y,.3}..� >,+rx:lC+.A4,' CTS .f tf' it
;�IY.�! + �r F`•• .�' M \ t ,� flAi_' / {rr x r y'I�y,� k
" ylY .: 4 ,,iy�ti ` I • � • � � 1,,' d 1 • ,�7' •�i•f.%rl� 1_ J� TY��II• � �} �✓S '�.\�
"'ITCH \ L! • ',. j ii -i M .V '�
�' iY3ir�'3%i�f? S -� � ���t5%iti � ! 7'• � U ''r' •�� C"l `C' µ 5 { " �+.. 4 ��LS.i"*4k51t �
(r1 ..-��dl'S: L.:�.x.. l..,�\T--i.. �� , \ y _.� '..i YV. ^`I:�wi4,'�^,w'1wF•��. � !'1 ..,,-...".GIs ta. ,tl�Nra

r,
t]i -- r ca it y , -: v.«: ti'•, - L
� 5 r • - ` ! � '• - ' " . ' . * � i ,. 1 ., �, � A k `�� :a v74'7 rSC+�+ .
WWI
' - :.. � `- ....� .,4.:...... -1 �- {A.. '^ r �':, fv %"'. } ., ., , �,Tr;-4; r e 3• i ieJ• �}�, ...•,„ .: -1 -�.. .. "�w ...._ _.. ,�,erx..•»..._ ,•Li;{
' 7 .i�-'. /� rr � �,�a�••.� •k t r �! .• J, r �4-:. ..e'er, ,r-•� c :.-, �� H "}. .�;ilf
r' \�! •` one c r r1j Y.- f t
%• Li,, tis� 4 tiw y x1} ran , t . t( '-./�- \ t w. ra.. It
r Ilk,
;kv .•✓ �„ Is..a1 ., ;.,. y1i,ti, - Q \ ,� s. t J �/rY .,�'. _ .1 .'1r a+C i:,.,,} � � r��:'r. t� - �.;�i �\I'� � � 't i .. _ :....... _ ._. J �`'
:t ]] ' •:�. 5 ry �j�� � , n - , \.. ` s,�.., �-'{� r ' ;�I!. e- �? xF' c. � ri�TC S} r+ r ri'�i ti �i Ci �`' u� � --� xv
M. sr, , V Y �'{ \-+ _r r N J: ' qq,,��. i� "2 • r l .,T,,. � `r (} ' 1
' 1 ::•i,yi3'al.,�- L i+, t \ Y .�. r-..��: Vl', �7;° {�`� w1_I �, •� sp„�}' {�']+''jw7�'t'I� 1 V-. �•(�. r� s :k,}-{t' 1'r,i ri
�w: ; i�m•,.� .� J f � t �'.� r•.�.
4. 7 M ill j` A v
.,. .,.�....�....�.+++ �_� ` vs� .1 ~'r,+i..ti y� •�Jt \ er�'i''►'' �j '�' R�j;iW, of t_�J rz'•���o it'li `� '• 'r''.
,�1 ;;: `.}13�Tc+r f �"6'.♦ AtJrti!
f�yz{-�` r,l fyF ti ,.,
.. J r ,;�i.. 4 y� (,� ;::.,, '�+�7., �+,. i�- 1'7 s.,,�?f �n„i„nt��L' �.•.} <.�. C�r-1�4�.. r .+hilt �4t�:�,r2}r+r it.'/ {> 1
KT-�O • �� , ^ ��,y. r� -] Lr iC4' ;`'' i �S'!«!`[? -r -.
_ -1�. _ - .. :� f ' ,- y S •. I. _ - �, 1 r� . '�t;: ' i'r��"� �-� `� . ;�*� �n t, _ -e• 1. .:;k• j , Nrh.y�� /;] .. f�.r,�?' "i:{ , � : F',:r G �,.Mr�:'^+:1°� T ,� y
. � � � vi'I � '� ,;� :;;.� '=" -;i- ` F"•�'�. !A •a . . ■ '�` �i l ,� ear �•,7�#ti r'�,�}....C„ :+C :+lj'_,:, k . -, `i:• JJ• rr , .,,,
�'�:
•Y• i• t"1 � % • \ . t' + el: ,•.': � f � r r{,.i, ,1•� s .q,.� � � : f � � t ,r.
`rl � -_ � 1 r 'r � rw t s.-".F iR', _rt�4r• NI � �Is !!- �K: �V,�:/ t, � R t r, r, . I .. y� 1-
.,J1
�".w.: f , 4. ';t vR; �7' -L.S. �'I: A'�,p�+��j,.t.�r.. _ '• y' /! �' I Gt{' , i I -.: J '' � r p - r �. �� ~'7•> .r..'�i.:
'rt
�4,, � r �t L :3' 1 f t '1� ':�Sv ?7t•�l�r�l�r:h 1!`d'J��/ ,f h'i�� 'i- t �ll�i ;V; �� st- rR�- �ri •� � i f �ltn: x ,
k8'! _vr,�, ., .. �i Cf� �l!'' =.i,,.-7!#•Ir-.:.-. zi"v:. J,as Qi I:aQnJ• !?- }{f
4• .. r 'X'r� r ai. ^97e
�' ,.•e •'•>' 1 i -'• t-r"".'%t•�f{r�'�,� �i,�, rl-J'i -fib �',�,f ,i i.;y�y�Ff i 1� kpS y�• j 'K y r r•y �7 ��`i3":'i
'r,',•_JC s {. :r.:,• .(, : .` i� _ 7 rry .rC�r ,x•�r� ' +l/,�i(yy■., j.,•:v I t +�-%;.crans;�4r-, . i:-L'<� luyr +' ,fa ;Q►..c
( I r„r-'. `,• •._ Y r 41 \ti7 i r s.e r , �I } �} ` din i
-•Mw't � �.. a-V��.•i�,7SS?•r{@ ,P- r' 'ett.i � r , { .
�c k,;.1: 1'`l. t -r., -> _ ^�4j� �,,1 5 1,� ��. ..r;'8.li�' kr �..1. +'�!, .�, f�'y. i�;:-u", •1,�L� �: -$'1 'n F r':-*rrk{ �rl £S� oJ:;tt r
,iy,Jr. S. - %� .••F + M: I ::_t r�. -,r L.•' { - {
711P.Ir Y fir. yir.. ..+r" .-YC' "'•'r2�, +'hhy.•�'?r ty�, �-` r' ,9• S „h:., 'r, b�,4+,1,.#�t :t.. .7' >' re, 5 a=•.x ( 41a<`1'.., <7,°J;-''fit' I: ], :,i.,' -IS• � ti .•�- `c�.?-.Mi� ��j :F�• •t� :r�'.� 'i,'S:q,1'.�•'I' �r.-'"q� i� �,+-'�"•^: rj:;.;. ,t• •s1,'..,, :r.,.
f'�A: { . , Y r ] ::tr -r� :•,%�. ia�4y �:,• ..,.� '�4. ♦. •.4' � �1 � re
�''{' T Y ���tia -�.C': [ y �'�, .7 •.r n'i5�€i. -4, {.. v;C, 1� `$j� � 3 nz.' ,
���-��!• -�- , J4 _ � � _.�. 'i :7'l'' k '\- .� .,,.y{ � ,,���5, �-C jp �, a,i„ r�'�s,r �. v .� .:F., !Y..{�?� LY' �, -s�r .�I ,r , +� '�j a+s3'i
i�; +,,I -!, s. LAX 7C �%� :%'t>.• 3•.,j,, ,t if C-: :I.. �`/5,,;�=i•,'�+ �dst• ,�'•e' ,%; + �., ,...{+.�`����-irr� r"�.�'e., #;i#!.�-i;�s r'c•• f� r. ,J i.
'r,.:.i•yy ,;r =. x �r f - �r r •._/ ,tP E.'� :�. , .: �+-,..•i '.ilkr:s�f" ' ' :;� � �� . F ' � / � 7 1
it r/�s.. � •'rs. �'7- r' 'y. �' a', _.! ,b. r,:� FJ•� '.f:yyis. 1\.',1- r>�� •� .:+'.�,t;n..-�,.,: �I;, •�. ?i'r �' FPJ.-,11�1".i.tiJ '7; �r�.::..�w.3�- �• .F.•�'��
rr. v . i' I{ ;n 4'�i j i •• ti L'#�'�, .6., r ask .,h �._ .� .b•/ i t: 1 �-i, +d•^_ +I..., •.f, ar s.o� s,
SSr,Vi �:' ',�y., '•4 i �i ,V1 `!�5.t :J, -iA �A�. <\, �' �.9 i:� JWr 't 'Y: !.•jjl ? �r r.�. ft ��•�.'�pJ.1�_ !r• i{ �,�4 �� I T, k{
.'1�, M,• _iYA. } q: ` .'J',n ,�i}s.j$:.f r - ,,,.d: '1.7 +�{,. ,iy r.- .�Ir ry �s. r - +.ii' 7�-Ci, �•F,?,U �I�•4i'. T,'�
:r•C . r, y=•t. ,/t , 1*�r, +• ' � 4f •lx" d �,s /r ::�.: ..'.4 i '"R �7 n !r`-�'.`i: ri. i �' a •'�14. "''I� �F y'• "•�,-ie, yrr'- s� ,� �' f y `.r:S ifx
/,;�khf7�?. "'�[:' d ,�' •,-sr }�,,.DI! h• r I ,���' •et. '.irl Jr�r'' .wr,x..++���`ly,: e1 �r .S /�� F .�,�. I �v-, 1':�)': fi,. J.,, '
•,#T']� _;ytE"'i. ' it ` 'f F'? i - y ;�:.ra :I r e `'S ; ,c%syr ; t., Sti �� .,,r ' �" - t g- }'T. 1} �', '„41d�'-! �'4�r } s L, } L•:••r '
ll'�, rJ: .t,. ?.,- ,,i i1�"j}-.�,�',..,"'►�•ti=.:r� r+.�'.r ��, :.�, :4 .,r•. l� u�'';h `/.' , R°.• rr;"�t, �.. ',I-!: >- cy�#' �i'�. -'� .o• 1�• �..�.• ,,, i _r�,. r+:��:
\`r:eti i., � .- 'rx t. ,�"",Lr,. Tr „rr %• % r .1. i, S -, tx1. �r- 174,C., {.. � •rC:T�•,l ta:
{..f a r''h• - s K S" ;' •s•'• ' 1' . '�,r ` ,•.•'i ,�c
'''� ► „{ _ ,x, r+ .,y{ trryi.` 'S.' ' � ,i <.> '�• .S;- �Y� ;� �� f►L' 't t r ! ` �i r. yy� L ��, �+ • /'�: it � ; •' � - �''.. 2 � )
�7yr
.� 7�•,.,hV' Y :'�'; }yam=n�� .,. ,tk.tr;l.c{.,,, e.."'� ';ti...,/ J "�s4r •'y° c1' k iiJ,:. k3 Y�Y�" yr'nl i 3✓!y'I`.a�4:I x,' :'1 Jf r.,e li
`;3r^r 4• .._ t :t,/ �� s ��, )ha>j'1i1 �;,ahgr �..,t -'`":B ;• , s." �' 1',
w r f.� i 1 ,'.I.: ►ram. �'
�3+r a : �% i A�
';�, :(G. � ",.��'�ti`�i^'�"r' �';7 "wfll �:°'y?k�'1'"'� , •' .e + '' -. I �t#T, t°s Ir�
's ` nd -yri} i�i�{a4� .� tp�,-t►• +. Y,-�isi�ker �5k V,�it\ +c .,7 '
{\ 4r"',•, r ,,,e ��+�.y',��:,. 'r '.C`. :� 4 (� '-tit lr a_; 7' rrE Q� `.rj, rt`,a.j ••s • Q .. ,�J 4 �: rhks .J;,,
, i;4� • r- �yt% •:h V6]0. 7 � ..`� � � � Cv ' �;�Jl'L}r �F,iM'. `�-. F w t - � !r,:3 �'�,{ r :�'�'C\ 11 r ` e \,,t�.`.� �, \!; . • ,f lf,�'I'!q� f r �i; r �S R.� • 37, r.
7-i�. 7+SI.�I.:s..n%t: q '! • �*: 'Y�^ „`' �i�'i�"'3l,. � • 1:�.-..�,.�� ,`. hi/� 'r 5r- ..i '�k it � A: f5T-
,'�'i fr :'7Yf"• rPi �t?,4 ,�'ki:*Ti<:`• t i r• �:.. ;..r A7% J• , r}s- - ��, 8 i
F- £v\\i .7 a `, i ;W�yly '� r 'I +i" .=Y-3r �..;r f%'fi. �It"'�::•Y�. :i4)� F ! icy ;s't W- r ( �\ ! '1" yEr•:.¢7, V!J ^Lk."' lrht:
1 -`a,yru
'�r:, '•ks,+ .;s •'C.��+L? Y_: , ,.`.' LM4]ta• �,:Fr•, •ni,' ,J r
y i tr� , 1 Fa�irr a qj yf��{(� y .r 1 -.�a �'' J
}.y rw'1 .�,`�-T,-J�7ris ^•.-C'>i ; ��. \� :�1 n r:`,;'f�riF'�' •F�� ` a
.- -:,. !y' �- r4 {.:.•t 1'fi:•,r,' .rr.'�, r 'la 1' .(.v's`,- is:. \. (.- V
_ .M .j :4a✓l .i'''µ"'l ''r''"ter _N%!'Y, rr \ 0 i.;.i G',!-I?r('vi'-s'�#:r., tt,'r•,a y�3� ti i�
'''•�,,-� :� � �•,.r�
s "•1, r1 a}f,,'r, S - Ir t r 1. . ''1t•rt'�. ' �'� ... C • 1 �'1d;. 1 k•II..r Y J� $x, .1...t.
ij�y>�t 1 '. :! ,,:.._.K oZ;!j`d, ?l fa� , !. ` .�+ \\ J7+ {F!i,. 1 V i�1r2,.,, AJt 3<r 7•Y vAa1
', iS e''eiri �^ �%. t' n «T» +'#!ijr�
':. F, r+;'•,' -= t y 1 p •'�r�,�-'J<•'�`'Tj `:�-. a�. .� f �J :.' \�\. .. .Y 's• ti } 1,.:: r: =' It ',Lr ,.lrgr tlr ,} ,
r..'�.� �,�.'la'2."„1�.•a+^'�'.s=4•�FI'�'_ ::e t tL'{jrv1..-r�iyl,.r•{��r�, �'- .� ,�.sU.. `, t .., :,ty, _ •'�:. „-'�ys' +. thy, ��:�a�� iS�i: i'��I�' ,`I�
7 f
:?rit�• , �,._ ,�."O �k r : a i4t--+� .'+ •t i_\ f+yh �7 '•i+,l..` ..• 1.. Y t �:�'.,�.
#pry hly F.rG 71i v ,.h• `,. �i. ��� '"L�y' L1'� -rr � r�.; �'ti-;'r tJy `i�1.
?.�•i r 1 •L �f x�� �,nly�'`� ::,,. '� % ` � �-. �,4 YI ,.7t:.r �,i ,.1, � °T �,5.. � V ��" i•�•� ;'.��,r i � ���'rG ` tiE 'r y :c .��t c!- �� ��.. .A �
S d ��t�t1f' d /.fir; 7-'gyp r �r , b �ar9 rid,y5. vtr 1 i t `Irus.,�Aj Y�;', vY ii a.
Yw'
'+ 111 ! A• -2L l!. i r ,�. i �_ �'����vh'ti -;F 'L,:'ry. �►. ;7' T t
r-t��.E,�'�dS�y� t,� � . i � l}i�h`�;+•j!y � ` /, �14-°S4t�r � ,�,1 1,..) x :, 7 _ -, r � .E.^•7 �' t
+�, 1 �`,til , ..#. i � 1 ]meµ:' ) t' y' r� � S s•pw -I �'7A�� i, .s�,,e.'y, � '`• i .'z,h ' t
r_�.y�\� ' i �; � 1 ,.��Z•,L •r't- sr• . ,,�r1 ��;$ :� �, Jr 4� n �•4s '��'iM°'i+•-'�
,i -�, � ` J's;41:1t �, t �3+rn-1, 'r'�=t: a��,t'i,, _r r `.�^,i't +, Q,•J7r r; "il, i :�+ � •a c>' ^f '.'.
•' '' ,;' �, � � . � 'y��.y},.3� Est ��1 � y/ .�' y � i'': '+•. .,� r Yr'r �S� �:•
• r r�. •r: tiFrt� ` ,\ \ +�'•!} _ 5 y,;'�,l '�i'� fr� �1�. �L. /' r':�..A .I+t 11 �-# -r � f;:� C {tt 'T� ir�4P's�,]RT•�.{ r- ` t r'li
ii• •,i -�'4y: \ � �' .. ��p � r '. r�ti"+.y.J�a ��,'�,� I �/ ., sf.. �;, •;.� r,71���:' f .,Ithe .tf�y� i1 �;,r ��rr ,..�4a�. i<'y� '� :t•
i.. , -, \ �\ A `• � V ;��' ,t, I ly�il:.1 :1-ham [ ,I .; } I Yi yi " .�:r sr a=7 'q '�g ',- r•
�q,:;r,p• ! C'' t.f �•'1, �1 %'�t7�,t1�''. nf>., •.''1'.f.�4.hy5"i,'_`+h5r "/.+S't"1�"j,,.,'�' k• f_�'*�yTi', -}tr'y {ri£ '�.; 4'.;',
_ _ I \ ;1 t�, 1,V t �. • t'�%: 1. .}.yf 'i ,7 �,'J�*. I, �,, ?�3 y1,�. `.'y.;�L.l;.�/•Y lty-:.l!"r'v �!.{I�s. - , r1.Yii.�"k� x{ Ra !
P'''r
ry, 1
y".:r:,
:1'„ 1,'. , t,.�-'It' <, �4.i�t dt% . u t i r rA A4Ri. r r t ;'j > ►-�11
�. 1 SYts ;, }i;:• i' - �' ••Rtl s„ t... 'r f v .F. n;. - ( r�4 ir,.1 K{`,1 r.. ! .�i }
k .,. 'S l�,J,� \ ^ft �• } 'a-�I �i 4'•�,,�iFJ�'+'f �'h;y' J r �� •'�� i,fy y�.dr •.• t4 ,e: n ,•
r _,.�..�. 1) � � r�,\ \ r: vy ,h Irt ,f':,�{ ] ryri ?y�`l�! � ��I��;:i,`r]� r - J,�.. ,� J, •�J:�hd� �• - •�' ,`i'1'r++�,3 � ..�}:'�(.''t p,Jq % i' s fa} . '��'r,
4 ' C .t - ' � ,rl *,'x v J,r�! � - r ii. � ( � - yi .f� k' j s'; ->• �i /�, ' ..IJ'.ua,% • a • .;r- . '��'1F�� try •'iCM1%'i�' •Y; ?° 7' ` Y' ii:
r-i r¢ � r \ tee, s: wS, --}` '{: �S �s �"Tr 3 � f}, s � l .�' wL�,TA ,ti ,i•� `:5�°ice 1 6f y, MS ..'•,F.
jV-..� `'] � _., : -/� i!rtr-.- .r •: � _z...?f�;,f��ti, � t`: {i�'k.'�:i�'i:.'1 )4-•'1:. J9'�'I:Y�+i$S'I d . :.h� vod.'h ia-",�'!4't.... '.I. +i'. rid` -'a i �Ji€r�f� .. .r7f.

... ......�:arr.-:.x.............+sac!-:e...........:.?.tf+r..!tys!+..xrn:.e!!?ef?:xr.•-.......: ..,.::.:-:.-::: sY::.�-»sp. ... {� _ _ :k3:
-L.:n�....:::::.....::: ::::: .._::::. .- : - -}.v: ..... Y: :.:-: ti• .. .'-=: _ _ fiY:.iri-i::ir r.}':.;'
......... ... .ti:.gin:. .....: :- ..: !-. .:. :..
:.i �, .:J��iv-:�:::'...:v _iii�`.:�:}.-..•.v .r :.vv :4..v:: ":.i}:-?'-'::'.-...... v..:f?:-;:?:�:4+:.-::�::-:.e::•:: .�...�.iii�: "::v' .-.v .-:�. ..v-•ve.::: xSvi+L4f.93LV+3:in3�:�:Cwo-;ai....-:._:.vn...rrni�if4:iimvmi4Y�_:+ii)Lix:fvf::Y.
..:.n.vvw-- t_mv-w.vmv..Av-w+�vmin.}:-WaviC++.v:� w:ri+Rn+n'wn:ifl.Y Y!"x'v'K4rcrc�}XSWrv�-x.
This plan will be implemented in the event that animal manure or lagoon effluent from your
operation is lealang, overflowing, or running off the site:
Step (1) Stop the release or flow of manure/effluent.
Step (2) Assess the extent of the spill and note any obvious- damages.
Step (3) Contact appropriate personnel and agencies.
Murphy Family Farms: 800-311-9458 or 910-289�6439 (See Land & Nutrient Management
phone list attached)
Department of Environmental Management (DEM) Regional Office:
DEM after hours emergency: 919-733-3942
Local Emergency Management System:_ qzj `" Al?t8
Local Natural Resource Conservation Service: --
Local Cooperative Extension Service. - .2-� 1
Local Soil and Water Conservation District:
Local dirt-moving/heavy equipment companies:
1.
2.
3.
Local contract pumpWaxitgadon equipment companies:
L_
2.
3.
Step (4) Implement procedures -as advised by MFF, DEM, and technical assistance
agencies to rectify the damage, repair the system, and reassess the nutrient
management plan to prevent future problems.
Note 1: See MFF Environmental Emergency Procedures Flowchart attached
Note 2: Seepages 89--91 of the Certification Training Manual for more details.

Land & Nufrienf Managerauu Cenificatian Manual
emei
ENVIRONMENTAL
which has
teurs
roi
EMERGENCY.
Irson
PROCEDURESMF'
Lagoon dike has
breachedlbroken out
I
n a temporary df Yes
be built to stop the Construct
discharge? temporary
dike.
No
the discharge Yes
t be contained o necessary to
property, contain spill.
Contact personnel in:
• Land & Nutrient Mngt
Heavy Equipment
s Sexvicperson
Pyramid Manager
Lagoon level has
suddently dropped
without irrigating.
an you menu No
the discharge
outlet?
Irrigation/flush systems
malfunctioned creating
a significant leak.
you capable�f - no
pine source a
Yes
Yes
Obtain
Take action
Attempt to
repairs b es
materials
you stop th
to stop
contain
made by farm
and snake
discharge,
discharge!
effluent on
personnel?
necessary
property.
repairs.
No
No
Cali LNM &
Contact LNM
Heavy Equipment, areas ur
tr
� -
personnel and
personnel, service
Pyramid
person and
Manager.
production
manager.
Monitor situation I. _ -
until help arrives.
ltun=.dot_ 03/29/96 04 ®MURPHY FAMILY FARMS

Land do Nutrient Management Cernficarion Manual
LNM personnel assess
options and call DEM.
helicopter need �r� Contact LNM to
assess containmen dispatch helicopter
options?. {available within 30
minutes).
LNM and Heavy
equipment personnel
identify equipment needs
and dispatch it to the site.
LNM personnel procures
Heavy Equipment and
maintenance staff as
needed to aid in response
to emergency.
LNM team will coordinate
response efforts. Meet with
DEM personnel and
document actions taken.
Inmcemdoc: 03129/96 65 ®MURPHY FAMILY FARMS

PHONE LIST
LAND & NUTRIENT MANAGEMENT TEAM
'Lf`'A4 office i -1 :-')!WN9-644?

a-.b 67) 5 l�lu1,W� 1
.'ANIMAL WASTE MA. .GEMENT PLAN CERTIFICA7 _ V FOR EXISTING FEEDLOTS
Please return the completed form to the Division of Environmental Management at the address on the
reverse side of this form.
Name of farm (Please print) :_ Qburn Nuc-se.r-Y _
Mailing Address: 41" /( sv a- US 112 1T`
County (of tarm): f„ I I
Farm location: Latitude and Longitude: 5-1 o i' OV sb (required). please attach a
copy of a county road map with location identified.
Type of operation (swine, layer, dairy, etc.) : Sw i n e.
Design capacity (number of animals)
Average size of operation (12 month population avg.):_ ab o c)
Average acreage needed for land application of waste (acres)
TechnicaI Specialist Certification
As a technical specialist designated by the North Carolina Soil and Water Conservation Commission pursuant
to 15A NCAC 6F .0005, I certify that the existing animal waste management system for the farm named,
above has an animal waste management plan that meets the operation and maintenance standards and
specifications of the Division of Environmental Management and the USDA - Soil Conservation Service
and/or the North Carolina Soil and Water Conservation Commission pursuant to 15A NCAC 2H.0217 and
15A NCAC 6F .0001 - .0005. The following elements and their corresponding minimum criteria have been
verified by me or other designated technical specialists and are included in the plan as applicable: minimum
separations (buffers); adequate quantity and amount of land for waste utilization (or use of third party);
access or ownership of proper waste application equipment; schedule for timing of applications; application
rates; Ioading rates; and the control of the discharge of pollutants from stormwater runoff events less severe
than the 25 - year, 24 - hour storm.
When checked, see reverse side of form for conditions/exceptions.
Name of TechnicaI Specialist (Please Print):
Affiliation (Agency): MICHAEL E. SUGG
Address (Agency): USDA, NAT. RES. CONS. SERV.
Signature:2 j �,} PO BOX 277 KENANSVILLE NC
TELEPHONE [phone]
OwnerlManager Agreement
I (we) understand the operation and maintenance procedures established in the approved animal waste
management plan for the farm named above and will implement these procedures. I (we) know that any
expansion to the existing design capacity of the waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the Division of Environmental Management
before the new animals are stocked. I (we) also understand that there must be no discharge of animal waste
from this system to surface waters of the state either directly through a man-made conveyance or through
runoff from a storm event less severe that the 25-year, 24-hour storm. The approved plan will be filed at the
farm and at the office of the local Soil and Water Conservation District.
Name of
Signature
Name of
Signature:
Date:
Note: A change in land ownership requires notification or a new certification (if the approved plan is changed) within 60 days of a title transfer.
DEM USE ONLY: ACE#

CERTIFICATION CHECKLIST 1 WORKSHEET
Name: Acfn'1Date �J
Technical Specialist IxJ (Tz
Size of Operation: yc -
COLLECTION
Are the houses adequate to properly collect and discharge the waste to a storage
facility? YES NO
STORAGE AND TREATMENT
Did NRCS Design Waste Treatment Lagoon?
YES NRCS Design Capacity (number of animals)
Has Operation been Expanded without NRCS assistance?
YES V NO
IF YES, what is current design capacity?
Dimensions (L x W x D) of lagoon
NO What is present design capacity
Dimensions (L x W x D) of lagoon
Does existing waste storage structure meet NRCS standards for a lagoon?
YES
NO Does structure have at least 60 days temporary storage,
24 hour - 25 year storm storage, and 1 foot of freeboard.
YES Number of Days of Storage
animals
NO NRCS cannot provide assistance unless
landowner is willing to increase storage
capacity.
Assess Seepage Potential of Existing Waste Storage Structure?
Soils similar to SP soils
Soils similar to SM soils
Soils similar to SC soils
Soils similar to CL or CH soils
High seepage potential
Medium Seepage potential
Low Seepage Potential
Very Low Seepage Potential
animals
Where seepage is a high or medium risk, NRCS will advise landowner of
potential seepage and recommend and offer a more detailed investigation at the
landowners request.
Is there any evidence of seepage? YES r� NO
If yes then NRCS cannot certify operation until seepage is corrected.

PRODUCER CERTIFICATION OF IRRIGATION EQUIPMENT
1, �, , certify that I own have access to) the
(producer)
following irrigation equipment:
TYPE IRRIGATION AND SIZE
AVAILABLE FROM
(uwncr of equipment)
E further certify that, through the arrangements I have made concerning irrigation equipment, I
will be able to irrigate as necessary according to my waste management plan.
Signature 41
(producer)
Date l S�
PRODUCER CERTIFICATION OF INTENT TO PLANT GRASS FOR
IRRIGATION
certify that I will plant the specified grasses
(producer)
as outlined in my waste management plan at the next available seeding date. If this seeding
date is in excess of 5 months from the date I stock animals, then I will provide a temporary
cover of small grain if needed for irrigation.
Signature
(producer)
Date

ANIMAL WASTE UTILIZATION PLAN
Producer: MIKE RABON
Location: 446 NC 50 & US 1.17
WARSAW NC 28398
Telephone:' 910-293-7093
Type Operation: Existing Wean to Feeder Swine
Number of Animals: 2600.00 pigs
(Design Capacity)
STORAGE STRUCTURE: Anaerobic Waste Treatment Lagoon
APPLICATION METHOD: irrigation
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops
in the fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply
more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall be applied to land eroding at less than
5 tons per acre per year. Waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on saturated soils, when it is raining,
or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed
under DWQ regulations.
Page:

ANIMAL WASTE UTILIZATION PLAN
5. Wind conditions should also be considered to avoid drift and
downwind odor problems.
6. To maximize the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more than 30
days prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. If
you choose to change methods in the future, you need to revise this
plan. Nutrient levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from your
waste management facility. In some cases you may want to have plant
analysis made, which could allow additional waste to be applied.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
This waste utilization plan, if carried out, meets the requirements
for compliance with 15A NCAC 2H .0217 adopted by the Environmental
Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
2600 pigs x .40 tons waste/pigs/year = 1040 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
2600 pigs x .48 lbs PAN/pigs/year = 1248 lbs. PAN/year
Applying the above amount of waste is a big job. You should plan
time and have appropriate Equipment to apply the waste in a timely
manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
Page: 2

ANIMAL WASTE UTILIZATION PLAN
TABLE 1: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
--------
APPLY
iRESID.
APPLIC
METH
N
TIME
71924
3
NOB
BP
4.6
230
4.5
1035
I
APR-SEP
71924 1-3
END
SG I1 150
I
I
- Indicates that this field is being overseeded (i.e.
interplanted) or winter annuals follow summer annuals.
4.5 1225
SEP-NOV
TOTAL11260
NOTE: The applicator is cautioned that P and K may be over applied
while meeting the N requirements. In the future, regulations -
may require farmers in some parts of North Carolina to have a
.nutrient management plan that addresses all nutrients. This
plan only addresses nitrogen.
Page: 3

ANIMAL WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
See required specification 2.)
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
---------
APPLY
RESID.
APPLIC
METH
N
TIME
END
TOTAL10
Indicates that this field is being overseeded (i.e. interplanted) or
winter annuals follow summer annuals.
In interplanted fields (i.e. small grain, etc, interseeded
in bermudagrass), forage must be removed through grazing,
hay and/or silage. Where grazing, plants should be grazed
when they reach a height of six to nine inches. Cattle
should be removed when plants are grazed to a height of four
inches. In fields where small grain, etc, is to be removed
for hay or silage, care should be exercised not to let small
grain to reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too -
high and this will definitely interfere with stand of
bermudagrass. This loss of stand will result in reduced
yields and less nitrogen being utilized. Rather than
cutting small grain for hay or silage just before heading as
is the normal situation, you are encouraged to cut the small
grain earlier. You may want to consider harvesting hay or
silage two to three times during the season, depending on
time . small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late
September or early October. Drilling is recommended over
broadcasting. Bermudagrass should be grazed or mowed to a
height of about two inches before drilling for best results.
Page: 4

ANIMAL WASTE UTILIZATION PLAN
** Acreage figures may exceed total acreage in fields due to
overseeding.
* lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and 2 above:
CROP CODE
CROP
UNITS
PER UNIT
BP
SG
HYBRID BERMUDAGRASS-PASTURE
SMALL GRAIN OVERSEEDED
TONS
AC
50
50
TABLE 1
TABLE 2
TOTAL
**
TOTALS FROM TABLES 1 AND 2
WETTABLE
ACRES
LBS AW N USED
4.5
1260
0
0
4.5
1260
* BALANCE
-12
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.
Page: 5

ANIMAL WASTE UTILIZATION PLAN
amounts of nitrogen shown in the tables may make this plan invalid.
The following table is -provided as a guide for establishing application
rates and amounts.
I I I (Application RatelApplic. Amount
Tract l Field l Soil Type I Crop I (in/hr) l (inches)
I I I I I
71924 1 3 l NOB l BP I .50 l *1.0
I I I I
71924 l --3 l l SG l .5 { *1
I
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations, the application amount shown cannot
be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180.00 days of temporary storage and
the temporary storage must be removed on the average of once every
6.00 months. In no instance should the volume of the waste be stored
in your structure be within the 25 year 24 hour storm storage or one
foot of freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply the
correct rates to the acres shown in Tables 1 and 2. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may
make this plan invalid.
Call your technical specialist after you receive the waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate prior to applying the waste.
NARRATIVE OF OPERATION
Page: 7

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge- during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 Filter Strip)
5. Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is.
danger of drift from the irrigation field.
6. When animal waste is to be applied on acres -subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be considered.
Page: 8

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take'up released nutrients. waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips)_
12. Animal waste shall not be applied closer than 100 feet to
wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged into surface waters,,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
."technical specialist'. Animal waste shall not be applied on
grassed waterways that discharges directly into water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
the site.
15. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 9

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
18. If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling
be inspected on
and spills. A
site.
structures, piping, pumps, reels, etc., should
a regular basis to prevent breakdowns, leaks,
regular maintenance checklist should be kept on
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22. Waste shall be tested within Go days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when these
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be
maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North
Carolina regulations.
Page: 10

ANIMAL WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm:RABON NURSERY
Owner/Manager Agreement
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
North Carolina Division of Water Quality (NCDWQ) before the new
animals are stocked. I (we) also understand that there must be no
discharge of animal waste from this system to surface waters of the
state from a storm event less severe than the 25-year, 24-hour
storm. The approved plan will be filed on -site at the farm office
and at the office of the local Soil and Water Conservation District
and will be available for review by NCDWQ upon request_
Name of Facility Owner: MIKE RABON
(Please print)
Signature: Date:
Name of Manager(If different from owner):
Signature:
Date:
Name of Person Preparing Plan: (Please pri.nt)BILLY W. HOUSTON
Affiliation:DUPLIN SOIL AND WATER CONSERVATION DISTRICT
Phone No. 910-296-2120
Address (Agency): PO BOX 277
KENANSVILLE NC 28349
Signature: v" Date: 4 -,9.p ^ ,j 0
Page: 11

ji
. .. .... . .. ..
pp
fl
t-7
7j-r±
--- LH
i -rT--
41
77-
T�
i iff
.-j
A-111 30411 1110;
W,Nj 1 131 11 1 0

T&TAn ST5RAGE AV4iLAILE
148140
Cu
F'.-,
/
5487
Cu
n0�
xnj'/mT `/r FILL
Cc
rt
PAD
30900
-----------
Cu
Ft
TOTAL
102660
Cu
Ft
SETTLEMENT 10%
10266
Cu
Ft
---------
TOTAL AMOUNT OF FILL
112926
Cu
Ft
4182
Cu
Yds
CUT TO FILL RATIO TOTAL EXCAVATION 122500 Cu Ft
1 1: 1 4537 Cu Yds
' c�� °/ '°� ��.�'�^ /"/����/ /
/,~' "~~' .. �~_'' —~ ' .

OPERA7I0M AND MAln[&PANH-
|l/: 1 lagoon is Jen';//au for wasxe treatmeot with mio'mum :Oor
^nonz'`i ' The t�`�r ,e���'es v^r t:e c a/Deo fluid !eve: to he
eac:odmay vary du* to sy. ,o:ditiors, flushing operations, and
0he Amount o' f'ei^ W�tor acoed ta t^`= s/stem.
LpnA� Rppjication of wasle water is reco9nized as an acceptable
.ovt|'"� oP 6/suo5, :' T'Y/8ation by center pivot, so| 10 set or
na`eior :s the orpfprred ano most e{f'cient metNow to dispose of
/.'c vpf/ue:t r'oo t�* /zSoor. Care Hou|a he taken when a:p!yinS
Vns?p Zo OrevP:� dauL?e to t|'c crcpl ^:d 00 orevc:t runoff f,wm
0 1 p0'�0_
The Toi|owing ite/s are to to czrr|cn qu7:
| pan', vamp -out ;P too /n3eon whom {i:;, |evz` rea�pes `o�crt
%- �01 aoopt mimes :r ;t x e e,ariGn
' ' �top p:c/'-n;z 5e;,.'e t", /�Pn,,. .7070 /s toss Onto 6 fe&-!;
--no or at a ie+tv. �701n oreve^ts tke ;nss ef
0`_/vYe "actcriA.-
/' in, amount to aDp:y ;-y i/r/?atfon is one inch,
s''c minimum recommended aup/lcztio: ,aoc is 0.5 inch per hour.
�� |� raco�';e��ec t^o� �ho tre���e:t !agsoo be prechzr3ed t�
in its capacity to pre -ern cxressive odors dur[nS beginning
`taqp* oF the Gperat|or. prcchurSing reduces the concentration of
�ne initiai waste entering the lagoon Hereby reducin8,ndors'
Sn! idv saouid be cvversd with water a7 a!| &mM'
S. Keep vegetation on the emnankment and areas around the ta800n
and buildings mowed.
6. Repair any eroded areas and establish in Vegetation.
?. The Clean Water Act of 1977 prohibits the discharge of
po!|utahts into waters of the United States. The Department of
Natural Resources and Community Development (DNRCD), Wastewater
Management Sectionr has the responsibility for enforcing this
|1w.
8. All surface water is to be diverted from the lagoon to an
adequate and stable outlet.
CERTIFICATION:
I hereby certify that I understand the oneration and maintenance
requirements stated above. Furthermore, I understand how many
acris are required in order to land aup|y the waste and that
the lagoon may have to be pumped 2 or more times a year. This
design has hesn explained to me and I agree with all provisions
statpo in the design. I also certify that there are no resHence
other than nine or my teoa:ti' uirrin 150 feet of tnis operation~
I understand that compliance with thin Jesion DOES NOT prevent
s��eo,e f rlrn ncaus ice or other reasons'
S 1 g:atvre^^ ��� /��i�,���'\_ �ate
,"- -�- --- -- - -/- - -~-

APPRCKINATE (N? AND PHOSPHOROS (P:
PO"S OF VQ�F STOAED�, 2 V,:-"
APPL�Eg TO YHE LAND 17 2%mU M 1NOLVil-D
70 DETEKAINE 1KE EXACT QUIRIEAf CADNTENT. THE N=n
AN Kmy!&N T1KRV0qAS 40551.2. Arim.yGMS, 'QTj SVOULD CONTA07,
ASfnNCmF& SERVjG±S WEVIS10"'!
r0lm: K.LK RIDGE ROnU CENIE:­ - ,.
RALEIGH N.C. ZT6Z.-,
jj 4 ly f ly LNOCIOL, A Fj Q 1 - 9�0 �L 1 09 D 19 K A AC
0EN&q CROP 5�M=u Cc 13V Tko- TTD TO �T &AGE10N.,
OR 1 A& 1 C A 04
0 S64
Lan� Avoi;,
(j
warrow to Foanny
ac.
oY croVand
pPanned to tar:
0.0 cc.
ot coastal
bermudagrass-"hay
0.0 ac.
of Pe5cue--Srazed
ERROR percent of land required is available
0 sow Farrow to Finish operation;
Land Avail. Land Required
0.0 ac. oP cropland planted to corn
0.0 ac. of coastal bermudagrass--grazed
0.0 ac. of coastal bermuclaSrasy--hay
0.0 ac. of fescue --grazed
ERROR percent of land required is available
BEGIN PUMPING THE EFFLUENT WHEN
THE FLUID LEVEL REACHES Elev 50.5 Boottom Outlet Pipe
------------------------------
DO NOT LOWER THE FLUID ANY
THA�`� Efev. 47.6 38 Ft. Below Pipe
------------------------------
GALLONS TO BE PSAPED EVERY 6 MON-HS 405092.5 gailom:
-
-
THE EFFELIKOT SHOULD K APPLIED AT k RA7E THAT WTuL NOT CAUSE IN
R15_10F7 Apsky W nEAMING YNTO THE eRDUM
RE&OXIEVNED APPFLTLATION RATO M 9.5 TNCHES PER K&UR PND T&'�:
NIM flix 141011,74Q0 Ap�llvp�'nv qKyArdy T7 1 TNQH FM

Name: Michael RayL- on
SEEDING SPECIFICATIONS
AREA TO BE SEEDED
- APPLY THE FOLLi--44I NG
USE THE SEED MIXTURE
INDICATED
i V )
1 .5 A C: .
1500 LBS. 8-8 FERTILIZER
TONS DOLOMITIC LIMESTONE
150 BALES SMALL GRAIN STRAW
TS LBS. FESCUE GRASS
52.5 LBS. OATS
75 LBS. f BAH I A GRASS
LBS. WEEPING LOVE GRASS
IS LBS. HULLED BERMUDA GRASS
=:0 Lj-'S . UNHULLED BERMUDA ';BRASS
DIVERT ALL WATER TO A STABLE OUTLET
THIS NEAREST RESIDENCE IS 1100 FT.
T.B.M. 50.00 ELEVATION
DESCRIPTION et in edge of woods I i rye approx. tF ft. South
of STA . A 0+00 .
VERY IMPORTANT - PLEASE READ CAREFULLY
THE LAGOON AND THE AREA AROUND THE HOG HOUSES MUST BE SEEDED WITH
EITHER A TEMPORARY Oy PERMANENT GRASS, DEPENDING ON THE TIME OF THE
YEAR, f WITHIN THIRTY 130) DAYS FROM THE TIME THE BUILDINGS ARE COM-
PLETED AND READY FOR USE. (WE RECOMMD THAHAT THE LAGOON AREA, SIDE
SLOPES, DRAINS AND ETC... AS WELL AS THE SIDE SLOPES OF THE PAD BE
SEEDED WITHIN FIFTEEN (15) DAYS AFTER CONSTRUCTION. THE SOIL WILL
NOT DRY OUT AS MUCH IF SEEDED WITHIN THIS TIME FRAME WHICH WILL
RESULT IN A MUCH BETTER STAND OF GRASS.)
PAGE S

DEPTH E AREA OF TOP + AREA OF BOTTOM + 4 X AREA '-IF M 1 DSEC:T 1 i=iN I
.VOL.iUVdE _ _-__- --- -------------------------•---
rµ,.r� 27
DFF'TN C L W 4- L f: W + 4. L
VOLUME= --•-----------------------------------------_--___--_
r_. 2- 7
L►Of.-.lJME --------- _ --------------------------------------------------
-27
(t't' _-8_43
VOLUME
=.(3 Z7
14:_:140 . Q CU . FT.
VOLUME =--__.--_--_
Z 7 . Cl
VOLUME = 5 _,t_.. 7 w-U . YD^ .
14501r:.0 cli. ft. needled
�:;UDE SLOPES e 1

■ ■mui rHUN
is s■i""
i'as':iaurpr�iu'■'lrmai■pi�i■ri■iri
s
■ f■
a
�.�.:�
i
iaaui■i■.
_
_saaiFi
"
�rrJruu■iois
�
'■
■iwitii ii �iiu■ii
+f.,Ar/■ar�pisaaat
rriilimamuia'aii
'mf■aiilr.��ia
rimrr�
O■Aii
ir1lrfaYFrff■rirOriwrd
■■11s■-i'"a
■wlrw
all
A
fwuiprtt.r.usat.w.i.rru
uiilraaurRll�s�■aRa■■uru
inN■rrar'up.
r}■A■r■■rri}
fusia
i�yyvre
ar
1
a1w1i111a
aifi■■r■11i
Oir
■Lr!■r■1lptirrrrrt■rrlraa■irn}prrarr
■trwn■liniri
Asir■rlriap
■■rtrri■prir
1■f
v
■a■■r■frii
1 ■■■1■■rir■rr!
Aft
rpfn■iF■■■■11rr1■■rr■p
mm
v.Fiur=■■r■■■ppi
annpr■at
flu■fist■14!•
�.
1af
,■ •
1rtlOfil■■n1�■}arr■rfia■lirtsriipirrla■l�llail■
iiiii
Olfuaa0l
ssiawn■■■
ufa■■wavalnlil■sa■
rl
■■r
iill,
�wfliRt■irFrrs
■■
Linuaawia■■■■■■■■t■sail■1n■r■■■
■r■n■awFipr[■■r/rr■r■tr
f■rrrfwiaa
futlnrr■
■y�.,y,w
`•
f■Afilflri
iiuiiiilliiii
rw
R�ian
rr!!lfrrr■irrrr}awa■f■■alrAla
-itssisaiRESUME
iiiiisaii
]'�iF���
'
Ar.■
r �I AJ'fi���
rU■■i"■1°i�iirwuu■nnw■uut�ar■uur�
w
7G��iiii�i�ime
rrr■r■■iwrlfsfi..w.f■rrtr�
mowiiliiiiiiii�
ME
lwtu}ar■■
0L{md{1R[Ios
rrirrsfrfuafuissstslriuoiful■suF■urrfu■u■paq■�i
rsi
s
r�
i1■p■irlrmrir�
SlAt
�'ii
r�1
mrY■!ra■fapallullapRai
onR�o
uasip■■Mapsa�■w■Fiarui
sipii
�RFp■auirii
ut!■�s7■�/!�]�n1F1�
���iri�wf�
� i■nr■■_of■■n■■■wrirr■r■n■■1■}■aR■uppa,
r t
u�
ir■■•ii�lsseiiiii
ago
a"iri
!suit
rta
q'3'slpi■l"'aivass
�■Y!A■w■�■!!
nt■i��linara■■■■t'fiiaaa
■�
■■
r■llrrall■���1:1y��
■�Arfta
1l�nr■ni■iF■■alni}s■n
■��f��%R�teifl
lr!■■■■luIR1wR
n■awinitirl■!w
■aili■ii■mMKMM1
a■■1■wF1a■lrr■1lyi�lr�ir�
inrirrfir�tilnr■Fra■tliraafaa}iifi
■wr■■■Afw
u
■
to■■i
"a"MU'
fr
Ar1W,
r!■
nr
!�
irRG
r�r
1r
�a
am,Frra■
■
ii1P
p
n■
i
it
rt1
iiiiaisa
�n�'!
ir!■!r}1r■rrifwrfa■
■u■rra
FFn■
wfwtfllr
rrisrui
wisfwimm
�F��■
u
V • •
rrrrillL■rnlia}l■■a■
u�'i■L�+Cia}�!t'Fiaaa
1na11■'�
■:�.
f"ss"�eCa7�G'sa
i�Ts
i
■ rr
■
s�'Tila
■iwiimanumn
am
iir
wifjr�■s+
siRiivi
i
RFl1■d■■■fff�aatl
■1:aa
■.■
n=Y!i
■ ML-
�s
wwa'uiu�aiS��i
i.
n"1a}n°Y'■
r.
r
•
1
}
■ F}}
■
F t�irwir
wrt■
i!
■irr
w
■
■r�wr�
iiiiirZii
i■
i'.■'=i...
■E
i■ali%F�!■aarr■M�i■
rriiiiia
i
■s�fuiaG�l
ii�i
i■.
'
�:■
Z
.l
Ba.;-:=i■lwiruufi
����iii�i'sis�®���iiiME
wooN
1ia■il�i�i'ai1mmE
2�8■�l■nn
"��
EM
■
ir■
ii■
■a
ii�i��
a
■
i�=�'fiiiiri
�m,�llo
Fs■�iliaass
GaiTeii:
■
i'�
iFr'aiiir

e
ILI
10 0
10 0
0
I
111. i
OWNERS
a
lum
0
:0,
1■
ORR
am
a =2
a
1
Im"Cou'll
a
IN
ME
moll
a
.Mm■an
11
Iffin
on■
a -
Il!
BEE
NJ
1111'
man
Us
...
1I...::
M.
0 am
MING10010
upujunij!getum
lmm:.ME
am.
MEN
.
XXXXX
a
.........
a
MR.:
110MUMORM
ROME
I
ON
Us
go
!HISOUSILOM1111
011111
slow
I
Moo
Im
all
a
Oman
MEevionolill"
Woman
wnnmm2.
Mason,
am
,
won
go
.1
mumn
Imaml-189.918
=10
No
--a
-a-
I"
a-
0
1
owns.all
.
..
jw%.
11
Hoommon
as
am
long:
in
INEW-11
DUN!
.100
'oil
onE
us
man
0
-1
I.:
a .
mu
S@
mmt::.m
MIR ME
ME
a
Wi
ITI
a in
oonso
. 110
.00
a
a
a
it
Room
-.10
us
a
His.
Wall
Lou
a
-
a
a
I
1AIS,A00ad iNi I H 104 ONY H tO i 't4 j IONI I ol oz x ot w(Ii :.iA

,lI,51A-�iASTE MANAGE'NT PLAN CERTIRCATION FOR NEW ip:; ' EXPANDFD FEEDLOTS
Please return the completed form to the Division of Environmental Management at the address on the reverse side .
• of this form.
Name of farm (Please print): / Y ._SC-eJA'72.P - - X1u12,f EIL4''�`
Address:_ 44-6 t1cf- S?2-
�_ Phone No:7dA_3—
County: - -
Farm location: Latitude and Longitude;Wel!aS' /?8`o?'2 (required). Also', please attach a copy of county road
map with location identified.
Type of operation (swine, layer, dairy, etc.) : c-J,'t1 TIL
Design capacity (number of animals): oo � •��.a
Average size of operation (12 month population avg.):6aa �a
Average acreage needed for land application of waste (acres)
Technical Specialist Certification
As a technical specialist designated by the North Carolina Soil and Water Conservation Commission pursuant to
the 15A NCAC 6F .0005, I certify that the new or expanded animal waste management system as installed for the
farm named above has an animal waste management plan that meets the design, construction, operation and
maintenance standards and specifications of the Division of Environmental Management and the USDA -Soil
Conservation Service and/or the North Carolina Soil and Water Conservation Commission pursuant to 15A NCAC
2H.0217 and 15A NCAC 6F .0001-.0005. The following elements and their corresponding minimum criteria have
been verified by me or other designated technical specialists and are included in the plan as applicable: minimum
separations (buffers); liners or equivalent for lagoons or waste storage ponds- waste storage capacity; access or
ownership or proper waste application equipment; schedule for timing of applications; application rates; loading
rates; and the control of the discharge of pollutants from stormwater runoff events less severe than the 25-year,
24-hour storm.
Name of Technical Specialist (Please Print):, J-O(Z
Affiliation: Ao LEcI r
Address (A ncy): �.$s� .ter Phone No. 16- 7
Signature: Date:, L6 =
Owner/Manager Agreement
I (we) understand the operation and maintenance procedures established in the approved animal waste manage mentan
plan for the farm named above and will implement these procedures. I (we) know that any additional expsion
to the existing design capacity of the waste treatment and storage system or construction of new facilities -will
require a new certification to be submitted to the Division of Environmental Management before the new animals
are stocked. I (we) also understand that there must be no discharge of animal waste from this system to surface
waters of the state either through a man-made conveyance or through runoff from a storm event less severe than
the 25-year, 24 hour storm. The approved plan will be filed at the farm and at the office of the local Soil and
Water Conservation District.
Name of Land O er 12
ease t : G 5
Signature: � .y ~� % Date:
Name of Manager,if different from owner (Please print):
Signature: _ _ Date: 6
Note: A change in Iand ownership requires notification or a new certification (if the ap oved plan is changed)
to be submitted to the Division of Environmental Management within 60 days of a title transfer.
DEM USE ONLY:ACNEW#

DUPLIN SWCD TECHNICAL REVIEW OF. SWINE
CERTMCATIONS PERFORMED BY NON NRCS OR DISTRICT
STAFF
NAME:
DATE RECEIVED: ,ff 17Z
SIZE AND TYPE OPERATION:
SWINE INTEGRATOR:
TECHNICAL SPECIALIST:
All plan documents have been received in SWCD office.
Waste plan appears adequate
Design was completed by MRCS
Design was completed by PE and not reviewed by NRCS
Does the design package contain the following components and does each appear to be
addressed properly according to MRCS Technical Guide standards.?
'�-- Collection
Storage
Treatment
f Operation and Maintenance (Land Application)
WAS A FIELD REVIEW PERFORMED BY SWCD STAFF
WAS THIS REVIEW BASED SOLELY ON THE DOCUMENTS SUBMITTED BY THE
TECHNICAL SPECIALIST:
REVIEWER'S SIGNATURE: -
DATE:
9

Johb R. LonW,sfey,'P.Ef Castle Hayne, North Carolina
Operator: Mike Rabon #2
County: Duplin
Distance to nearest residence (other than owner):
• 1. AVERAGE LIVE WEIGHT (ALW)
0 sows (farrow to finish)
0 sows (farrow to feeder)
0 head (finishing only)
0 sows (farrow to wean)
2,600 head (wean to feeder)
0 head (other than swine)
Describe other:
Date: 11 /20/95
1,100.0 feet
X 1417.0 lbs. =
0
lbs.
X .522.0 lbs. —
0
lbs.
X 135.0 lbs.
0
lbs.
X 433.0 lbs. —
0
lbs.
X 30.0 lbs. =
78,000
lbs.
X 20.0 lbs. =
0
lbs.
Total Average Live Weight =
78,000
lbs.
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 78,000 lbs. ALW x Treatment Volume(CF) / lb. ALW
Treatment Volume(CF)/Ib. ALW = 1.00 CF/lb. ALW
Volume = 78,000 Cubic Feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0.0 Cibic Feet (As Per Owner's Request)
4. TOTAL DESIGNED VOLUME
Inside Top Length:
____>
156.00
Feet
Inside Top Width:
156.00
Feet
Top of Dike -Elevation:
___= >
102.40
Feet
Bottom of 4-agoon Elevation:
---_>
92.70
Feet
Freeboard Height:
-==>
1.00
Feet
Side Slopes (Inside Lagoon):
=--_>
-3.00:
1.
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDE SS/SIDE2 LENGTH WIDTH DEPTH
3.00 3.00 3.00 3.00 150.00 150.00 8.70
AREA OF TOP
LENGTH * WIDTH =
150.00 150.00 = 22,500 Sq. Ft. (Area of Top)
AREA OF BOTTOM
LENGTH " WIDTH =
97.80 97.80 =
9,565 Sq. Ft. (Area of Bottom)

John R. Lonfestey,'P.E. Castle Hayne, North Carolina
Operator: Mike Rabon #2 County: Duplin Date: 11/20/95
AREA OF MIDSECTION
LENGTH * WIDTH * 4
123.90 123.90 = 61,405 Sq. Ft. (Area of Midsection * 4)
Cu. Ft. = [Area Top + (4*Area Midsection) + Area Bottom] * Depth/6
Cu. Ft. = ( 22,500 + 61,405 + 9,565 )
Total Designed Volume Available = 135,531 Cu. Ft.
5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
156.00 156.00 -
Buildings (roof and lot water)
24,336 Sq. Ft.
0.0 Sg. Ft. Describe this area:
Total Drainage Area = 24,336 Sq. Ft.
Design temporary storage period to be
180 days.
5A. Volume of waste produced
Feces & urine production in gal. / day per 135 lb. ALW =
Volume = 78,000 lbs. ALW / 135 lbs. ALW * 1.37 gal/day
Volume = 142,480 Gals. or 19,048 Cu. Ft.
5B. Volume of wash water
1.45
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume = 0.0 Gallons / day * 180 days storage / 7.48 gal per CF
Volume = 0.0 Cubic Feet

John R. Lenfesfey; P.E. Castle Hayne, North Carolina r`r
Operator: Mike Rabon #2 County: Duplin Date: 11/20/95
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall = 7.00 Inches
Volume = 7.00 In. * DA / 12 Inches per Foot
Volume = 14,196 Cubic Feet
5D. Volume of 25 year - 24 hour storm
Volume = 7.50 In. * DA / 12 Inches per Foot
Volume = 15,210 Cubic Feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 19,048 Cubic Feet
5B. 0 Cubic Feet
5C. 14,196 Cubic Feet
5D. 15,210 Cubic Feet
TOTAL 48,454 Cubic Feet

John R. Lenfestey, P:E.
Castle Hayne, North Carolina
Operator: Mike Rabon #2
6. SUMMARY
County: Duplin
Temporary Storage Period: ---_--__—_--_>
Rainfall in Excess of Evaporation:==—=--------=>
25 Year - 24 Hour Rainfall: —_-- -------- >
Freeboard Height: ' ===========>
Side Slopes (Inside Lagoon):
Inside Top Length:
Inside Top Width:
Top of Dike Elevation:
Bottom of Lagoon Elevation:
Total Required. Minimum Volume: ============ >
Actual Design Volume:
Seasonal High Watertable Elevation(SHWT) ====>
Stop Pumping elevation:
Must be > or = to the SHWT elev.:
Must be > or = to min. req. treatment el.: ___=>
Required Minimum Treatment Volume:
Volume at Stop Pumping Elevation:
Start Pumping Elevation:
Must Be at Bottom of Freeboard & 25 Yr. Rainfall:
Actual Volume Less 25 Yr.- 24 Hr. Rainfall:
Volume at Start Pumping Elevation:
Required Volume to be Pumped: ==-- --=====>
Actual Volume Planned to be Pumped: _—.—>
Min. Thickness of Soil Liner When Required:====>
7. Designed By: John Lenfestey, P.E. Approved By:
DATE: i(�2d[ DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION
COMMENTS:
Date: 11 /20/95
180 Days
7.00
Inches
7.50
Inches
1.00
Feet
3.00
: 1
156.00
Feet
156.00
Feet
102.40
Feet
92.70
Feet
126,454 Cu. Ft.
135,531 Cu. Ft.
94.30 Feet
98.70 Feet
94.30 Feet
98.70 Feet
78,000 Cu. Ft.
81,106 Cu. Ft.
100.50 Feet
120,321 Cu. Ft.
116,001 Cu. Ft.
33,244, Cu. Ft.
34,895 Cu. Ft..
"'H„C jA
o
.,RFeet
O
of -
E
29
LENF�so�.

i
John R. Lenfestey,
508 Florence Drive
Castle Hayne, NC
Farm Operator:
Date:
P. E.
28429
Mike Rabon #2
11/20/95
OPERATION AND MAINTENANCE PLAN
This lagoon is designed for waste treatment (permanent storage) with minimum
odor control. The time required for the planned fluid level to be reached
(permanent + temporary storage) may vary due to soil conditions, flushing
operations, and the amount of fresh water added to the system.
The designed 6 months temporary storage is an estimated volume based on:
1) waste from animals
2) excess rainfall after evaporation
and . 3) the largest 24 hour (one day) rainfall that occurs on the average
of once every 25 years.
The volume of waste generated from a given number of animals will be fairly
constant throughout the year and from year to year.
Page 1
This estimate is based on 7.00 inches of excess rainfall which is equal
to or exceeds the highest 6 months excess in a year. The average annual excess
rainfall is approximately 8 inches. Therefore, an average of 8 inches of excess
rainfall will need to be pumped each year. The 25 year rainfall will. not be a
factor to consider in an annual pumping cycle, but this storage volume must
always be available. A maximum elevation is determined in each design to begin
pumping and this is usually the outlet invert of pipe(s) from the building(s).
If the outlet pipe is not installed on the elevation to begin pumping, a
permanent marker must be installed on this elevation to indicate when pumping
should begin. An elevation must be established to stop pumping to maintain the
minimum treatment depth of 6 feet.
Pumping can be started or stopped at any time between these two elevations
for operating convenience as site conditions permit, such as weather, soils,
crop; and equipment in order to apply waste without runoff or leaching.
Land application of waste water is recognized as an acceptable method of
disposal. Methods of application include solid set, center pivot guns and
traveling gun irrigation. Care should be taken when applying waste to
prevent damage to crops.

John R. Lenfestey, P.E. - r. Page 2
508 Florence Drive
Castle Hayne, NC 28429
Farm Operator:
Mike Rabon #2
OPERATION AND MAINTENANCE PLAN (continued)
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be precharged to 1/2
of its capacity to prevent excessive odors during start-up. Precharging
reduces the concentration of the initial waste entering the lagoon, thereby
reducing odors. Solids should be covered with effluent at all times. When
precharging is complete, flush buildings with recycled lagoon liquid. Fresh water
.should not be used for flushing after initial filling.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see attachment)
before land application.
3. Begin pump -out of the lagoon when fluid level reaches elevation 100.50 feet
as marked by the permanent marker.
Stop pump -out of the lagoon when fluid level reaches elevation 98.70 feet
or before the fluid depth is less than 6.00 feet deep (this prevents
the loss of favorable bacteria).
The designed temporary storage volume less the 25 year - 24 hour
storm volume is 33,244 cubic feet or 248,666 gallons.
As stated before, this volume will vary considerably from year to year.
4. The recommended maximum amount to apply per irrigation is one (1) inch
and the recommended maximum application rate is 0.3 inches per.hour.
5. Keep vegetation on the embankment and areas adjacent to the lagoon mowed
annually. Vegetation should be fertilized -as needed to maintain a vigorous stand. ,
6. Repair any eroded areas or areas damaged by rodents and establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable outlets.
8. Keep a minimum of 25 feet of grass vegetated buffer around waste utilization
fields adjacent to perennial streams. Waste.will not be applied in open ditches.
Do not pump within 200 feet of a residence or within 100 feet of a well.
9. The Clean Water Act of 1977 prohibits the discharge of pollutants into waters
of the United States. The Department of Environment, Health and Natural
Resources, Division of Environmental Management, has the responsibility
for enforcing.this law.

John R. Lenfestey, P.E. Page 1
508 Florence Drive
Castle Hayne, NC 28429
Farm Operator: Mike Rabon #2
Date: 11 /20/95
SPECIFICATIONS FOR CONSTRUCTION OF WASTE TREATMENT LAGOONS
SECTION 1: CLEARING
All trees and brush shall be removed from the construction area before any
excavation or fill is started. Stumps will be removed within the area of the
foundation of the embankment, all fill Areas and all excavated areas.
All stumps and roots exceeding one (1) inch in diameter shall be removed
to a minimum depth of one (1) foot below final grade. Satisfactory disposition
will be made of all debris.
The foundation area shall be loosened thoroughly before placement of
the embankment material. The lagoon site (and pad site if needed) is to be
stripped of topsoil (minimum of 3") and stockpiled for use on dike and pad
slopes (finished depth of 2-3").
SECTION 2: CUT-OFF TRENCH
A cut-off trench (when specified) shall be installed as shown on the plans.
SECTION 3: CONSTRUCTION
Construction of excavated and earthfill areas shall be performed to the neat lines
and,grades as shown on the drawings. Deviations from this will require prior approval
of Quarter M Farms and/or the SCS. Earthfill shall be placed in a maximum of 6" lifts
and shall not be placed in standing water. Compaction shall be performed by the
construction equipment or by a sheeps-foot roller, or other equivalent methods
approved by the Engineer.
The embankment of the lagoon shall be installed using the more impervious
materials. Construction of fill heights shall include twenty (20) percent overage
for compaction and settlement.

- John R. Lenfestey, P.E.
508 Florence Drive
Castle Hayne, NC 28429
• Farm Operator: Mike Rabon #2
Date: 11 /20/95
SPECIFICATIONS FOR CONSTRUCTION (Continued)
----------------------------
To protect against seepage, when areas of unsuitable material are
encountered, they will need to be excavated to a minimum of one (1) foot
below grade and backfilled and compacted with a SCS approved material
(ie - CL, SC, CH). Refer to the soil investigation information in the plans
for special considerations. Precautions should be taken during construction
to prevent excessive erosion and sedimentation.
SECTION 4: VEGETATION
All exposed embankment and other bare constructed areas shall be seeded
to the planned type of vegetation as soon as possible after construction
according to seeding specifications sheet.
Page 2

John R. Lenfestey, P.E.
• 508 Florence Drive
Castle Hayne, NC 28429
+ Farm Operator: Mike Rabon #2
Date: 11 /20/95
SEEDING RECOMMENDATIONS
------------------
Acres of Fescue Grass:
0.0
Acres of Bahia Grass:
0.0
Acres of Hulled Bermuda Grass:
0.0
Acres of Rye Grain:
1.5
Acres of Rye Grass (Temporary vegetation):
1.5
Total Area to be seeded: 1.5 Acres
Use the following seed mixtures indicated:
0.0 Lbs. Fescue Grass @ 60 Lbs./Acre
(Best suited on clayey or wet soil conditions)
Seeding Dates: September 15 To November 30
0.0 Lbs. 'Pensacola' Bahia Grass @ 60 Lbs./Acre
(See Footnote No. 1)
Seeding Dates: March 15 to June 30
0.0 Lbs. Hulled Bermuda Grass 0 8 LbsJAcre
(Suited for most soil conditions)
Seeding Dates: April 1 to July 31
45.0 Lbs. Rye Grain @ 30 Lbs./Acre (Nursery for Fescue)
60.0 Lbs. Rye Grass @ 40 Lbs./Acre (Temporary Vegetation)
Seeding Dates: December 1 to March 30
105.0 Total Lbs. seed mixture are required for this application
Page 1

10
John R. Lenfestey, P.E.
508 Florence Drive
Castle Hayne, NC 28429
Farm Operator: Mike Rabon #2
Date: 11 /20/95
SEEDING RECOMMENDATIONS (Continued)
Apply the following to the seeded area:
1,500.0 Lbs. of 10-10-10 Fertilizer @ 1000 Lbs./Acre
3.0 Tons of Dolomitic Lime C 2 Tons/Acre
150.0 Bales of small grain straw @ 100 Bales/Acre
it
' Page 2
All surface drains should be installed prior to seeding. Shape all disturbed
areas immediately after earth morning is completed.
Apply lime and fertilizer, then disk to prepare a 3 to 4 inch smooth seedbed.
Apply seed and firm seedbed with a cultipacker or similar equipment.
Apply mulch and secure with a mulch anchoring tool or netting.
Note 1: Pensacola Bahia Grass is slower to establish than common berm uda
grass. When using Bahia, it is recommended that 8 Lbs./Acre
of common Bermuda be included to provide cover until the
Bahia Grass is established.

ANIMAL WASTE UTILIZATION PLAN
Producer: MIRE RABON
Location: 446 NC 50 & US 117
WARSAW NC 28398
Telephone:- 910-293-7093
Type Operation: Existing Wean to Feeder Swine
Number of Animals: 5200.00 pigs
(Design Capacity)
STORAGE STRUCTURE: Anaerobic Waste Treatment Lagoon
APPLICATION METHOD: Irrigation
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops
in the fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of -the crop to be
grown and the nutrient content of the waste. Do not apply
more nitrogen than the crop can utilize.
2. Soil types are important as they have,different infiltration:
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall be applied to land eroding at less than
5 tons per acre per year. Waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on saturated soils, when it is raining,
or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed
under DWQ regulations.
Page: 1

ANIMAL WASTE UTILIZATION PLAN
r 5. Wind conditions should also be considered to avoid drift and
downwind odor problems.
6. To maximize.the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more than 30
days prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. If
you choose to change methods in the future, you need to revise this
plan. Nutrient levels for different application methods -are not the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from your
waste management facility. In some cases you may want to have plant
analysis made, which could allow'additional waste to be applied.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in'the optimum range for specific
crop production.
This waste utilization plan, if carried out, meets the requirements
for compliance with 15A NCAC 2H .0217 adopted'by the Environmental
Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
5200 pigs x .40 tons waste/pigs/year = 2080 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
5200 pigs x .48 lbs PAN/pigs/year = 2496 lbs. PAN/year
Applying the above amount of waste is a big job. You should plan
time and have appropriate equipment to apply the waste in a,timely
manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
.._ .� ._. Page: 2

ANIMAL WASTE UTILIZATION PLAN
TABLE 1: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
--------
APPLY
RESID.
APPLIC
METH
BP
N
TIME
435
2
NOB
4.6
230
9.6
2208
I
APR-SEP
435 1-2
END
SG I1 ISO
I
I
Indicates that this field is being overseeded (i.e.
interplanted) or winter annuals follow -summer annuals.
9.6 1480
SEP--NOV
TOTAL12688
NOTE: The applicator is cautioned that P and K may be over applied
while meeting the N requirements. In the future, regulations
may require farmers in some parts of North Carolina to have a
nutrient management plan that addresses all nutrients. This
plan only addresses nitrogen.
Page: 3

ANIMAL WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
See required specification 2.)
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
--------
APPLY
RESID.
APPLIC
METH
N
TIME
END
TOTAL10
-- Indicates that this field is being overseeded (i.e. interplanted) or
winter annuals follow summer annuals.
In interplanted fields (i.e. small grain, etc, interseeded
in bermudagrass), forage must be removed through grazing,
hay and/or silage. Where grazing, plants should be grazed
when they reach a height of six to nine inches. Cattle
should be removed when plants are grazed to a height of four
inches. in fields where small grain, etc, is to be removed
for hay or silage, care should be exercised not to let small
grain to reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too
high and this will definitely interfere with stand of
bermudagrass. This loss of stand will result in reduced
yields and less nitrogen being utilized. Rather than
cutting small grain for hay or silage just before heading as
is the normal situation, you are encouraged to cut the small
grain earlier. You may want to consider harvesting hay or
silage two to three times during the season, depending on
time small grain is planted in the fail.
The ideal time to interplant small grain, etc, is late
September or early October. Drilling is recommended over
broadcasting. Bermudagrass should be grazed or mowed to a
height of about two inches before drilling for best results.
Page: 4

ANIMAL WASTE UTILIZATION PLAN
• ** Acreage figures may exceed total acreage in fields due to
overseeding.
* lbs AW N (animal waste nitrogen) equals total required nitrogen
r less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and 2 above:
CROP CODE
CROP
UNITS
PER UNIT
BP
SG
HYBRID BERMUDAGRASS-PASTURE
SMALL GRAIN OVERSEEDED
TONS
AC
50
50
TABLE 1
TABLE 2
TOTAL
TOTALS FROM TABLES 1 AND 2
WETTABLE
_ACRES
9.6
LBS AW N USED
2688
0
0
9.6
2688
* BALANCE
-192
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.
Page: 5

ANIMAL WASTE UTILIZATION PLAN
• *** This number must be less than or equal to 0 in order to fully
utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffers, filter strips along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full application raters due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than
the acres shown in the tables.
See attached map showing the fields to be used for the utilization of
animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient
rich and will require precautionary measures to prevent over application
of nutrients or other elements. Your production facility will produce
approximately 395.2 pounds of plant available nitrogen per year in the
sludge.
If you remove the sludge every 5 years, you will have approximately 1976
pounds of PAN to utilize. Assuming you apply this PAN to hybrid
bermudagrass hayland at the rate of 300 pounds of nitrogen per acre, you
will need 6.58666666667 acres of land. If you apply the sludge to corn at
the rate of 125 pounds of nitrogen per acre, you will need 15.808 acres
of land. Please be aware that these are only estimates of the PAN and
land needed. Actual requirements could vary by 25o depending on your
sludge -waste analysis, soil types, realistic yields, and application
methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the
soil at the time of irrigation such that runoff or ponding occurs. This
rate is limited by initial soil moisture content, soil structure, soil
texture, water droplet size, and organic solids. The application amount
should not exceed the available water holding capacity of the soil at the
time of irrigation nor should the plant available nitrogen applied exceed
the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables I and 2. Failure to apply the recommended rates and
Page: 6

ANIMAL WASTE UTILIZATION PLAN
amounts of nitrogen shown in the tables may make this plan invalid.
The following table is -provided as a guide for establishing application
rates and amounts.
Tract Field
435 2
1 1
435 i -2
Soil Type
NOB
Crop
BP
SG
Application RatejApplic. Amount
(in/hr) ' (inches)
.50
.5
*1.0
*1
* This is.the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations, the application amount shown cannot
be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180.00 days of temporary storage and
the temporary storage must be removed on the average of once every.,
5.00 months. In no instance should the volume of the -waste -be stored
in your structure .be within the 25 year 24 hour storm storage. or
foot of freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste.applicator to
ensure that the spreader equipment is operated properly to apply the
correct rates to the acres shown in Tables 1 and 2. Failure -to apply,
the recommended rates and amounts of nitrogen shown in the tables may
make this plan invalid.
Call your technical specialist after you receive the waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate prior to applying the waste.
NARRATIVE OF OPERATION
Pager 7

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surf ace waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge- during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
S. Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is.
danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be considered.
Page: 8

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
10. waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste -nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to
wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged into surface -waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
."technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly into water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
the site.
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 9

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
18. If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and'
implementing a "-closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be .kept on
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22. Waste shall be tested within 60 days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate -- determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when these
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be
maintained for five (5) years.
23. Dead animals will be disposed of in a -manner that meets North
Carolina regulations.
Page: 10

ANIMAL WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of Pa=: RABON NURSERY 2 &3
Owner/Manager Agreement
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
North Carolina Division of Water Quality (NCDWQ) before the new
animals are stocked. I (we) also understand that there must be no
discharge of animal waste from this system to surface waters of the
state from a storm event less severe than the 25-year,.24-hour,
storm. The approved plan will be filed on -site at the farm office
and at the office of the local Soil and Water Conservation District
and will be available for review by NCDWQ upon request.
Name of Facility Owner: MIKE RABON
(Please print) i
Signature: Cr Date: " �7
Name of Manager (If different from owner) :
Signature:
Date:
Name of Person Preparing Plan: (please print)BILLY W. "HOUSTON
Affiliation:DUPLIN SOIL AND WATER CONSERVATION DISTRICT
Phone No. 910-296-2120
Address (Agency): PO BOX 277
KENANSVILLE NC 28349
i
Signature: Vv Date
Page: 11

� .fir � y +L � • ��v _ ...!"`� ' "`� ' .xi
�1:, .1�5� i '� r �Rt ,`��f`��• � �r.r' ''�_1,���5^tw. ,�•r � � 1,�-'�'. �'7; �'� .
_ .?"'�``•G a r��r' � ` �' � `i
,� ., ��{ R'f sy C)Sl -.O, A �. .... 't r.: . 7J,: iy,; p ' i:• -, r '"" � '1 - r ii
. VJ4"!1Tra. r� . � � x..... _ _ryi.'.`. � ��" a .f F r r 4T"!/►. �� 'i • r '- .. ..
y � , a9��u • �'+ `;'^ .S�� ''h%� :�7 � '•" n " •_:..y�,.. ,� :} . �I � 1 ` ' - „� w•� i GCS � .
wtrs�a "�-` n�-`r �.,*" �f•.r. r:7 ` r'�S .,l�.w ., V ,r.ti!. •— `.
54,
''��-! d �`�`'� '1E ;;..: �i ���!�s^,;'.�e!s;1�'?�tr'i�. �r =: �a'�: •,:, � , �i � —'r . ' `:.: �,. -x, f ` f � � — ��,�,.`
+; •.;=r,_,- '��'
'�.`I•,�jti.• �Y..��r(�+ � �:..:t�.' •Ay A - `i iW
ni r t1 R� t,i� a
�'' � -a � y'� � � ¢may �'� 7,t � �. �� � � •� � ;•
cn
i'j I `,�� y' � � :� � �' �\ +O � �' � �• � y� �. 1:. ii ry.i. _:.ti '1K's�l±"�'�'��+ _ � �: � f'rl � .
QI [D
f �~��* ti�ti•. j! � sty i�ri ��� � 1• �_. ^' S! �y,���`%' �R A�'�i /•/ ~
el
. -d 1 � �^u� r.l� ra.d�+�_r�r,•_ �' . � �wti . S a,� � � ?5 x��'% \'` / ti+�7'.::::r.-.
.� ` . `' ''Y r�l lr }fS,.=a; t a sib I'\\ ,} �-!" •I fV� \ \� • ri
lu
:1 •.11 �.. - Y' .. H I I :' I rile `'� �'. \ 1 � .; " ..
� 14 � +F � , may.. ,.•�r. a.�:rs� \ W p'. \\ ` \'�Cf3 .�y.+',* 'd�'.
�A-� S , : �"'J.�'+tTl'St'1:.+�!l� _. ___ .-__.- _ _ _ _ +�-} _ i.1:.r- \ �•e:�`.�.�_Sr. �._F�e..�, y ���
x .
M,

JY •�
{� v
n' �. '� a is d r; ���>;I � • •� D �f�}y�Y� � �6t � '�;r ~ r �
�j� _ l 7• �,. ry t� C4Isr}�y Z3; Z y- ,t ,� 'Z �s�,�f ° dT i r'j' / � � �tf"' � �• .t -
fy
' �,. �i d. p V-•Y F' ` _ � �e _ , f 4"I ��YA,�f. � •a{.>< wpA'F�.r��. .iC, fL} � t} �^ f' _ - � l;<'S�'M{j h', l M � + i ,, �j�'
(D
•"1' Y ''t',�.i �'�i /: L '" i>ti� �rl�'i}�r" r'l�(' � ' ' 1� r, ii
r � .�•.I'1 a �' M 1- rtl f �, �•, K+ w f ^. F"
�ivit � � �, _ 5 �r'rt �s " f �}! 6�. r x�i'•rh c *'S?d �J J- �� � \��� '„r�: ar.., /. T � ti� °' '�•: �5 r��,
'S}? i 7�' ;i� trt rt'L'� k Y +'C�..� r \�L•+' 1 � a.''' i h' t'' �ft� to ,y �� t• ?,, :y �tx 1�� 'i sC :y.' ���=r'+�, '�t'�iru �.! �'� ,�,. ,.>, � �� d ,� ; { . 5 ,;�'sr►++
¢ro
i�,Y}' s'i'i
+ • "w � _ ti' ' _
-F � L.,+,.• f to i ti 'f''1 i ',„If�'.f4� } � �J— �'� �'��� 1
"yykj y �/ ``� " � 7�5 �v. � 'S"�'r iT�l jf, •'�` f n > x� W •r' �• v
r ;t. j ;•^ ..�?" i sxr ; o y', 4 �
'r ., + 4 ls�Y t `� ° r °r" ��•� �/ • �'�i�•t.aKr y r y y' }, i
�„ 'U,:'': � �;'���, �� .t aJ�� ;'u.i,>,yT ia+. - � "=�%�xr��. �q 1} �IW"`ti�Y_k ''r1. ''."', E- �y;.•
co, .� r Y,A `!." lM i :i, is All..
!` +•t„�{}.• ' S:
� �' � t,•.''k�'m. J'y� ' f s 1� 1' f� Z Nsi b•: Q �' �y� "4N'� - d �•�, ffl L�
' tS "T `i' d, RI`�'•'� Y5 'r'l, i 1 Mr;�' ��'4�t �,'� � � z I ��Lsf� S' O { '�P
• v c. A Let{•-i t}. ' ; r,� � r +a• s,
�. �, r ..'.•'+ Phi'<' e:k.,+ _ tl",� ro - `x'�, 1 / •.
�� '
{{ F i
!•`- i ij��`, �U • `�'� O + �'7 � y s -n
-� V '• q.h M �; t t '.� a F' �.>R h� 1. ((��,, ' I�tLl �. ( r!
�lyt,•! �•'i75r' ^ I�
�Y,-� •1l'r��r '� 4 � �, hi t'!"r` .a �i�,. f�a i L��µ'.dY—�. ,��fi '.
+y' y' iP}', ' C5. 1 � K � � .,t` �y � � jf � ✓� 'y�. i�',
a _ L , r{.F{', £i ti:�� �„'yrafF.,i�F, ` r•,•r,Tf,. * re ' ; `� /� o
tir,�. � fit„ } • t `� " 'l r i� - f d 7 S3f''. ¢ `��'' ����rd �f�d ! �
�` d ��% �, '�"' �, r,•. � f ' � ' / � CXF� 5, � r'r i ; yc, ti �. - t�'�`" G ..'p. u ./•
3:� � � �� : �.�•.�l; ,t .it� >r; � p,. � � •� T 'rl�, �.. "tip? i 1 •d4 {�a t'S�'� ''•i"2!'r'1!
i•} T �� � y � AF � � , rl:tys yl�, • •,�'.,r, r r� i+, Qi•�1� 1 r�t �,04'6iz _ ,t��{,r��r�i y +�i ��"' .4 � � r
" ��:' x, '1" � ' !� N " 4 ••"4k 27'.. .. '. r. - '-) ' 1' �f .• t y,•-'t2�e 7'��► ry} 1 �.
" ti r* r � . 5'�>+ +r I' i rr' �, o r r LAY' i t + ,,x�' "4 r-• D
` 45 `� y O � ,� ry.y 5t 1� iF' r ..�� o Y:.'r v � � Y � � vita^, 4- f• 41 0 ? '��A'i. 1c S• G+ � • ~ .� ' i
Ow
:'7 • L -r f`ht � T",+M r .�Y�
'j �f r'3♦''1 .� :"f'f A:"+I'•ps�aiT' 1�'
�t 47] ���rlrttr/55 �",• .��jII e.,� �di{� 14�"r�+' f�f'tt "� �.Ar.,:.� � 'r 3 si'�.
r n t � 17'�1 „ iQ� f •' a -'I 'xu. Jr. 1���1"d•' +'ir 1i'Er.•, Q' / r
1 - 'i✓r+ J.r y 'fit 1 •-_ ,T co
,. � ��!" try^ •�... �'� ti 't4i$IS � '1 � �' ,>,tf-' •� rl. 3� �� co
�E -� ,^"V. ', • �+s=vS` � I a r /'i�r� .F,� 1., 13j. r "�+ a�, * Q�%� Ir � � .,.>,5� i;-.yr
•°' •'F'r?'Tf X'p � n ',f r c v �,� _ i4, r"'� -,p r{rr ., n�•.,��r+��.�%
n,
..�e ` � y • '� 1 r it's
i.'R-4 r►
9
S-+-A A,1>5
,� �•�i�P'Yh �. �aS f �i6k�Y�� ,� r
V, � '{• Y yrl,1�•"

Tr~
��i� "�\
4 � \�
!� ��
��
��
u
rr
r,

1 1'F�IF t,.. h +°i -f4 J '„ uryl�� F' ' I 'PI µ _ `` : , r•' N -
ul
i S +d1 n66,�' � C.' �Y. ,�i��.t' I' k j`a ,+�y i:S� �.�`•' _�., t 11 1,+.
j it 't
•.'' _� 1 '.� �. �, I - isrr,� 4 -tl, 1.1;y' ���.rTi i�:�h" :`b ��1'\ .L�. ,i• �0
\ � � 1 � � °� � �.1 .. ��-••fir
q aI1
li' ti Ilu 1 IL
N
:•4:
sf ' .

LAGOON SITE SOILS INVESTIGATION
PROJECT:
M, KF
,dZ COUNTY.
FIELD INVESTIGATION EY:t(% DATE:
S[T SKETCH
� r
A
i
1 1
�-'BWING. -
=DEP7-i
WT•
BORING NUMBER AND PROFILE
V-S - ALE
�
d = Z
14,
0
Z S
ly- /S
/aG /lam l�i�re8'
��•/s`
CoN�SE f.*-� %ffC�a
C 6Qi
I
`. ��
RN4 o IlSi
-
BORINGI SAMPLING METHOD: 7�clachydc, SIGNATURE:

SOIL INVESTIG,.00N TO DETERMINE SUITABILITY OF ROPOSED POND SITE '
FARMER'S NAME ar'] a^ DISTRICT ;
DATE ..— . _ L 1 - q.5 COUNTY-
S. C. S. PHOTO SHEET NO- WORK UNIT
WATERSHED AREA MEASUREMENTS
CROPLAND ACRES PASTURE ACRES
WOODLAND ACRE5 TOTAL ACRES POND CLASS WORK UNIT CONSERVATIONIST
SKETCH OF PROPOSEWPOND SHOWING WHERE, BORINGS WERE MADE (Approz scale It'= feet)
Locale refcrenc< point ?n center line o/ darn and ldenli/y on skefrA
■■■■■■■■■■■■
■■■■■■■■■■■■■
■
■
■■■■■■■■■■■■■■■■■■■■■■
■■■■■■■
■■■■
■■■■■■■■■■■■■
■■■■■■■■■■■■
■■■■■■■■■■■■■
■■■■■■■I
■iiI
■■■■■■■■■■■■■■
f130,VG
s
NUMBER AND PROFILE
ja.ke
ffnued an back whery nects=ryJ SA*w water table alewtiarts an dam -site borings.
���i■I■I■i■i■I■1■
®I■?■1■I■1■I■I■1■I■I■I■I■!■I■
;��I■1■i■I■I■�■I
l�I■I■I■!■1■I■I■1■I■�■1■I■!■!■
®
""�i■i■I■■I■i■1�®I■I■1■I■i■I■I■I■1■i■I■1■1■1■
l�■■f■1■1■i■I■I■I■
■I>■1■1■1■I■I■1■1■1■1■I■I■I■1■
ll�!!�[I�I�I■!■I■i■I■
[�I■I■!■1■I■I■I■1■1■1■I■I■1■I■
mmilsim.
ME
1■I■ORE--
I■I■I■I■I■1■I■I■10101010
��I■1■I■!
�■i■�■ICI■!■I■I■I■I■I■i■!■I■I■I■I■
W
IEI
!i■I■i■I■'
I■
NIMI
INININIMMINIMI■I■
BORINGS M kDF BY SIGNATURE & Ti"I'LE

LAGOON SITE SOILS INVESTIGATION
PROJECT:
14,9E
COUNTY: I�hPc,,J
FIELD INVESTIGATION BY'�DATE:
SIT SKETCH .
1
- l 177
"
--,TbRING. -
.
D?TH
WT-
BORING NUMBER AND PROFILE
lJ 7
-f jwt e,.,,r C«
-
3.Swf
Z
Goer ,J
I: S L
6 Y
! i
"LAI
nlp�FL 1�•�r✓I�il✓G !
BORINGI SAMPLING METHOD: 'rFr�GK�oG SIGNATURE:

]perator:MIKE
RABON#2
County:
DUPLIN
Date:
10/03/95
]idtance to nearest residence
(other
than
owner):
1500.0
feet
L.AVERAGE LIVE WEIGHT
(ALW)
0 sows
(farrow to
finish)
x
1417
lbs.
=
0
lbs.
0 sows
(farrow to
feeder)
x
522
lbs.
=
0
lbs
0 head
(finishing
only)
x
135
lbs.
0
lbs
0 sows
(farrow to
wean)
x
433
lbs.
-
0
lbs.
2600 head
(wean to feeder)
x
30
lbs.
=
78000
lbs
Describe other
0
Total Average Live Weight =
78000
The
?. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 76000 lbs. ALW x Treatment Volume(CF)/lb. ALW
Treatment Volume(CF)/lb. ALW = 1
CF/lb. ALW
Volume = 78000 cubic feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0.0 cubic feet
TOTAL DESIGNED VOLUME
Inside top length (feet) ---------------------
156.0
Inside top width (feet)------------------------
156.0
Top of dike elevation (feet) --------- - -------
102.4
Bottom of lagoon elevation (feet)------------
92.7
Freeboard (feet) -----------------------------
1.0
Side slopes (inside lagoon)------------------
3.0 1
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH
WIDTH
DEPTH
.3.0 3.0 3.0 3.0 150.0
150.0.
8.7
AREA OF TOP
-_
LENGTH # WIDTH =
150.0 150.0 22500 ( AREA OF
TOP)
AREA OF BOTTOM
LENGTH f WIDTH =
97.6 97.8 9565 (AREA OF
BOTTOM)
AREA OF MIDSECTION
LENGTH WIDTH * 4
123.9 123.9 61405 (AREA OF
MIDSECTION
4)
CU. FT. _ [AREA TOP + (4*AREA MIDSECTION) + AREA
BOTTOMS
* DEPTH/6
22500.0 61404.8
9564.6
1.5
Total Designed Volume Available = 135531 CU. FT.

3. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
156.0 156.0 24336.0 square feet
Buildings (roof and lot water)
0.0 square feet Describe this area.
TOTAL DA 24336.0 square feet
Design temporary storage period to be 180 days.
iA. Volume of waste produced
Feces 8 urine production in gal./day per 135 lb. ALW 1.37
Volume' = 78000 lbs. ALW/135 lbs. ALW * 1.37 gal/day 180 days
Volume = 142480 gals. or 19048.1 cubic feet
B. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in.5A.
Volume = 0.0 gallons/day 180 days storage/7.48 gallons
per CF
Volume = 0.0 cubic feet
C.' Volume of rainfall in excess .of evaporation
Use period of time when rainfall exceeds evaporation -by largest amount:
180 days excess rainfall - 7.0 inches
Volume = 7.0 in * DA / 12 inches per foot
Volume.= 14196.0 cubic feet

SD. Volume of 25 year - 24 hour storm
• Volume = 7.5 inches / 12 inches per foot *" DA
Volume = 15210.0 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A.
19048
cubic
feet
5B.
0
cubic
feet
5C.
14196
cubic
feet
5D.
15210
cubic
feet
TOTAL 48454 cubic feet
�. SUMMARY
Temporary storage period____________________>
180
days
Rainfall in excess of evaporation====_____=>
7.0
inches
25 year - 24 hour rainfall===_______________>
7.5
inches
1.0
feet
Side slopes_______________________ __________>
3.0
. 1
Inside top length=====______________________>
156.0
feet
Inside top width===_________________________>
156.0
feet
Top of dike elevation=====__________________>
162.4
feet
Bottom of lagoon elevation===_______________>
92.7
feet
Total required volume=====__________________>
126454
cu. ft.
Actual design volume===.____________________�>
135531
cu. ft.
Seasonal high watertable elevation (SHWT)===>
94.3
feet
Stop pumping also.__________________________>
98.7
feet
Must be > or = to the SHWT elev.====______>
94.3
feet
Must be > or = 'to min. req. treatment el. _>
96.7
feet
Required minimum treatment volume=====______>
78000
cu. ft.
Volume at stop pumping elevation=====_______>-
81106
cu. ft.
Start pumping elev:=
100.5
feet
Must be at bottom of freeboard & 25 yr. rainfall
Actual volume less 25 yr. 24 hr. rainfall==>
120321
cu. ft.
Volume at start pumping elevation=====______>
116001
cu. ft.
Required volume to be pumped=====_______==-_>
33244_cu.
ft.
Actual volume planned to be. pumped=====_____>
34895
cu. ft.
Min. thickness of soil liner when required==>
DESIGNED BY:,
/ljff'
APPROVED BY:
DATE:
/0- G- Q X
DATE:
Ml e.195
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
COMMENTS:

This lagoon is designed for waste treatment (permanent storage) and
180 days of temporary storage. The time required for the planned
fluid level (permanent and temporary storage) to be reached may vary
due to site conditions, weather, flushing operations, and the amount
of fresh water added to the system.
The designed temporary Storage consists of 180 days storage for-
(1) waste from animals and (2) excess rainfall after evaporation. Also
included is storage for the 25 year - 24 hour storm for the location.
The volume of waste generated from a given number of animals will be
fairly constant throughout the year and from year to year, but excess
rainfall will vary from year to year. The 25 year rainfall will not
be a factor to consider in an annual pumping cycle, but this storage
volume must always be available.
A maximum elevation is determined in each design to begin
pumping and this is usually the outlet invert of pipe(e) from
building(s). if the outlet pipe is not installed at the elevation to
begin pumping, a permanent marker must be installed at this elevation
to indicate when pumping should begin. An elevation must be established
to stop pumping to maintain lagoon treatment depth.
Pumping can be started or stopped at any time between these two
elevations for operating convenience as site conditions permit, such as
weather, soils, crop, and equipment in order to apply waste without
runoff or leaching.
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set,
center, pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent damage to crops.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre -
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent .at all times. When precharging is complete,
flush buildings with recycled lagoon liquid. Fresh water should.not
be used for flushing after initial filling.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see attachment)
before land application.
3. -Begin temporary storage pump -out of the lagoon when fluid level
reaches the elevation 100.5 as marked by permanent marker. Stop pump -
out when the fluid
level
$n a Ql levelreaches ,elevation9••�8..7 �+ } This temporary
`„ lees; 2, )f' qp; 3P
248666 gallons.

4. The recommended ma"um amount to apply per it gation ie
� one (1) inch and the rL mmended maximum applicat7� rate is 0.3
Inch per hour. Refer to the waste utilization plan for further details.
5. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
outlets.
B. Keep a minimum of 25 feet of grass vegetated buffer around
waste utilization fields adjacent to perennial streams. Waste will
not be applied in open ditches. Do not pump within 200 feet of 'a
residence or within 100 feet of a well. Waste shall be applied in a
manner not to reach other property and public right-of-ways.
9. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Environment. Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.

SPECIFICATIONS FOR CONSTRUCTION OF WASTE TREAT ENT LAGOON a
__ - ------�---�-____I----------------------__- -�---(fir-_---_--...- -
FOUNDATION PREPARATION."
-------------------------
The foundation area of the lagoon embankment and building pad shall be
cleared of trees, logs, stumps, roots, brush, boulders, sod and rubbish.
Satisfactory disposition will be made of all debris. The topsoil from
the lagoon and pat[ area -should be stripped and stockpiled for use oil
the dike and pad areas. After stripping, the foundation area of the
lagoon embankment and building pad shall be thoroughly loosened prior
to placing the first lift of fill material to get a good bond.
EXCAVATION AND EARTHFILL PLACEMENT;
--------------------------------------
The completed excavation and ea•rthfil.l shall conform to the lines,
grades, and elevations shown on the plans. Earthfill material shall
be free of material such as sad, roots, frozen soil, stones over
6 inches in diameter, and other objectionable material. To the extent
they are suitable, excavated materials can be used as fill. The fill
shall be brought up in approximately horizontal layers not to exceed 9
inches in thickness when loose and prior to compaction. Each layer
will be compacted by complete coverage with the hauling and spreading
equipment or standard tamping roller or other equivalent method.
Compaction wi.l.l be considered adequate when fill material is observed
to consolidate to the point that settlement is not readily. detectible.
NOTE THE SPECIAL REQUIREMENTS FOR PLACEMENT OF LINERS IN THE LINER
SECTION OF THIS SPECIFICATION. The embankment of the lagoon shall be
installed using the more impervious materials from the required
excavations. Construction of fill heights shell include 5 percent for
settlement. Dikes over 15 feel; in height and with an impoundment
capacity of 10 acre-feet or more fall under the jurisdiction of the NC
Dam Safety Law. They height is defined as the difference in elevation
from the constructed height to the downstream toe of the dike.
Precautions shall be taken during construction to prevent excessive
erosion and sedimentation.
LINER: THE MINIMUM REQUIRED THICKNESS SHALL BE 1.5 ft.
MOTE: LINERS (PARTIAL OR FULL) ARE REQUIRED WHEN THE ATTACHED SOILS
INVESTIGATION REPORT SO INDICATES OR WHEN UNSUITABLE MATERIAL IS
ENCOUNTERED DURING CONSTRUCTION. A TYPICAL CROSS SECTION OF THE LINER
IS INCLUDED IN THE DESIGN WHEN LINERS ARE REQUIRED BY THE SOILS REPORT.
When areas of unsuitable material are encountered, they will be over --
excavated below finish grade to the specified depth as measured
_perpendicular to the finish grade. The foundation shah be backfilled
as specified to grade with a SCS approved material (ie - CL,SC,CH).
REFER TO THE SOILS INVESTIGATION INFORMATION IN THE PLANS FOR SPECIAL
:CONSIDERATIONS.

Sai•1 liner material shall come from an approved borrow area_ The
minimum water content c( :the liner material shall ( optimum Moisture
content which relates to that moisture content when the soil is k.neadpd
in the hand it will form a ball. which does not readily separate. Water
shall be added to borrow as necessary to insure proper moisture content
during placement of the liner. The moisture content of the liner
material shall not be less than optimum water content during placement.
The maximum water content 'relates to the soil materiel being too wet:
for efficient use of hauling equipment and proper compaction. Proper
compaction of the l.iner'includes placement in 9 inch lifts and
compacted to at least 90 perceiit of the maximum ASTM D698 Dry Unit
Weight of the liner material.. When smooth or hard, the previous lift
shall be scarified and moisteiied as needed before placement of Ithe next
lift_
The single most important factor affecting the overall compacted perme-
ability of a clay liner, other than the type of clay used fr)•r thr•-
liner, is the efficient c0o_15tructi.01_1 processing of the compacted liner.
The sequence of equipment use and the routing of equipment in an estab-
lished pattern helps assurea ur,i.formity in the whole placement and
compaction process. For most clay {soils, a tramping or sheepsfoot
roller i.s the preferable type of compaction equipment.
The soil liner shall be protected from the discharge of waste outlet
pipes. This can be done by using t-ome type of energy dissipate-f-(rocks)
or using flexible Outlets 01; waste pipes.
Alternatives to soil. liners a•r•e synthetic liners and bentonite'sealant.
When these are specified, additional construction specificatio-i-is are
included with this ConstrLkCtion Specification.
CUTOFF TRENCH:
---------------
A castoff trench shall. be constructed under the embankment area when
shown on a typical cross section in the plans. The final depth of the
cutoff trench shall be determined by observation of the foundation
materials.
VEGETATION:
All exposed embankment and other bare constructed areas shall be seeded
to the planned type of vegetation as soon as possible after construc-
tion according to the seeding specifications. Topsoil should be placed -
on areas of the dime and pad to be seeded. Temporary seeding or mulch
shall be used if the recommended permanent vegetation is out of season
dates for seeding. Permanent vegetation should be established as soon
as possible during the next period of approved seeding dates.
REMOVAL OF EXISTING TILE DRAINS
-------------------------------
.When tile drains are encountered, the tile will be removed to a minimum
-of 10 feet beyond the outside toe of slope of the dike. The tile
trench shall be backfilled and compacted with good material such as
SC, CL, or CH.

♦ ^ F
s'^ SEEDING SPECIFICATIONt'
A r a rr r�r nrrrtrrt + r a rtinrr.
Arirzii l u tat= Z)lCtur_u_ l M /Auritb
USE THE SEED MIXTURE INDICATED AS FOLLOWS:
90.0 LBS_ FESCUE GRASS Al'_ 60 LBS ACRE
(BEST SUITED ON CLAYEY OR WET SOIL CONDITIONS)
SEEDING DATES: SEPTEM BE R 1 TO NOVEM BER 30
FEBRUARY 1 TO MARCH 30
45.0 LBS. RYE GRAIN AT 30 LBSJACRE (NURSERY FOR FESCUE)
0.0 LBS. 'PENSACOLA' BAHIA GRASS AT 60 LBSJACRE
(SEE FOOTNOTE NO. 1)
SEEDING DATES: MARCH 15 TO JUNE 15
0.0 LBS. HULLED COMMON BERMUDA GRASS AT 0 LBS,/ACRE
(SUITED FOR MOST SOIL CONDITIONS')
SEEDING DATES: APRIL 1 TO JULY 31
15.0 LBS_ UNHULLED COMMON BERMUDA GRASS AT 10 LBSJACRE
SEEDING DATES: JANUARY 1 TO MARCH 30
60.0 LBS. RYE GRASS AT 40 LBSIACRE (TEMPORARY VEGETATION.)
SEEDING DATES: DECEMBER I TO MARCH 30
LB�Q.
APPLYTHE FOLLOWING:
1500.0 LBS. OF 10-10-10 FERTILIZER (1000 LBSJACRE)
3.0 TONS OF DOLOMITIC LIME (2 TONS/ACRE)
150.0 IRALES OF StA LL GRAIN STRAW (100 BALES/ACRE)
ALL SURFACE DRAINS SHOULD BE INSTALLED PRIORTO SEEDING_ SHAPE
ALL DISTURBED AREA IMMEDIATELY AFTER EARTH MOVING IS COMPLETED.
APPLY LIME AND FERTILIZERTHEN DISKTO PREPARE A 3 TO 4 INCH
SMOOTH SEEDBED. APPLY SEEDAND FIRM SEEDBEDWITH A CULTIPACKEER
OR SIMILAR EQUIPMENT. APPLY MULCH AND SECURE WITH A MULCH
ANCHORING TOOL OR NETTING.
1. PENSACOLA BAHIAGRASS IS SLOWERTO ESTABLISH THAN COMMON
BERMUDA GRASS. WHEN USING BAHIA, IT IS RECOMMEN DE D THAT 8
LBSIACRE OF COMMON BERMUDA BE INCLUDED TO PROVIDE COVER
UNTIL BAHIAGRASS IS ESTABLISHED.

bv)-, 5 3
ANBIAL WASTE MANAGEMENT PLAN CERTIFICATION FOR IYE,"FOR EXPANDED FEEDLOTS
Please return the completed form to the Division of Environmental Management at the address on the reverse side
of this form.
Name of farm (Please print):)-K-43
4t.)39 0 Phone No:
County:__
Farm location: Latitude and L.ongitude:3: Q''.�'/a'id?` ""(required). Also, please attach a copy of county road
map with location identified.
Type of operation (swine, layer, dairy, etc.) /ty -L�
Design capacity (number of animals): OAS z3Le�
Average size of operation (12 month population avg.): 1212�6w
Average acreage needed for land application of waste (acres)_
Technical Specialist Certification
As a technical specialist designated by the North Carolina Soil and Water Conservation Commission pursuant to
the 15A NCAC 6F .0005, I certify that the new or expanded animal waste management system as installed for the
farm named above has an animal waste management plan that meets the design, construction, operation and
maintenance standards and specifications of .the Division of Environmental Management and the USDA -Soil
Conservation Service and/or the North Carolina Soil and Water Conservation Commission pursuant to 15A NCAC
2H.0217 and 15A NCAC 6F .0001-.0005. The following elements and their corresponding minimum, criteria have
been verified by me or other designated technical specialists and are included in the plan as applicable: minimum
separations (buffers); liners or equivalent for lagoons or waste storage�-ponds; waste storage capacity; access or
ownership or proper waste application equipment; schedule for timing of applications; application rates; loading
rates; and the control of the discharge of pollutants from stormwater runoff events less severe than the 25-year,
24-hour storm.
In I _ r— _ __.._.._
Name of Technical
Affiliation:
Address (Agen }:
Signature:
—
Owner/Manager Agreement
1 (we) understand the operation and maintenance procedures established in the approved animal waste management
plan for the farm named above and will implement these procedures. I (we) know that any additional expansion
to the existing design capacity of the waste treatment and storage system or construction of new facilities will
require a new certification to be submitted to the Division of Environmental Management before the new animals
are stocked. I (we) also understand that there must be no discharge of animal waste from this system to surface
waters of the state either through a.man-made conveyance or through runoff from a storm event less severe than
the 25-year, 24-hour storm. The approved plan will be filed at the farm and at the office of the local Soil and
Water Conservation District.
Name of Land. O wner Plea . e Print) : � f
Signature: ;, /� ' Date:
Name of Manager,if different from owner. (Please print):
Signature:_ Date: 6
Note: A change in land ownership requires notification or a new certification (if the appr ed plan is changed)
to be submitted to the Division of Environmental Management within 60 days of a title transfer.
DEM USE ONLY:ACNEW#

John R. Lenfestey, , P. E.
Castle Hayne, North Carolina
Operator:. Mike Rabon #3
County: Duplin
Distance to nearest residence (other than owner):
1. AVERAGE LIVE WEIGHT (ALW)
0 sows (farrow to finish)
0 sows (farrow to feeder)
0 head (finishing only)
0 sows (farrow to wean)
2,600 head (wean to feeder)
0 head (other than swine)
Describe other:
Date: 11 /20/95
1,500.0- feet
X
1417.0
lbs. -
0
lbs.
X
522.0
lbs. -
0
lbs.
X
135.0
lbs. =
0
lbs.
X
433.0
lbs. =
0
Ibs.
X
30.0
lbs. =
78,000
lbs.
X
20.0
lbs. -
0
lbs.
Total Average Live Weight =
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 78,000 lbs. ALW x Treatment Volume(CF) / Ib. ALW
Treatment Volume(CF)/Ib. ALW = 1.00 CF/lb. ALW
Volume = 78,000 Cubic Feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0.0 Cibic Feet (As Per Owner's Request)
4. TOTAL DESIGNED VOLUME
78,000 lbs.
Inside Top Length:
-__;>
125.00
Feet
Inside Top Width:
200.00
Feet
Top of Dike Elevation:
____>
100.50
Feet
Bottom of Lagoon Elevation:
90.50
Feet
Freeboard Height:
-=__>
1.00
Feet
Side Slopes (Inside Lagoon):
3.00:
1
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDE SS/SIDE2 LENGTH WIDTH DEPTH
3.00 3.00 3.00 3.00 119.00 194.00 9.00
AREA OF TOP
LENGTH * WIDTH =
119.00 194.00 - 23,086 Sq. Ft. (Area of Top)
AREA OF BOTTOM
LENGTH * WIDTH =
65.00 140.00 - 9,100 Sq. Ft. (Area of Bottom)

John R. Lenfestey, .P.E. Castle Hayne, North Carolina
Operator: Mike Rabon #3 County: Duplin Date: 11/20/95
AREA OF MIDSECTION
LENGTH * WIDTH * 4
92.00 167.00 = 61,456 Sq. Ft. (Area of Midsection 4)
Cu. Ft. = [Area Top + (4*Area Midsection) + Area Bottom] * Depth/6
Cu. Ft. = ( 23,086 + 61,456 + 9,100 )
Total Designed Volume Available = 140,463 Cu. Ft.
5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
125.00 200.00
Buildings (roof and lot water)
25,000 Sq. Ft.
0.0 Sg. Ft. Describe this area:
Total Drainage Area = 25,000 Sq. Ft.
Design temporary storage period to be
180 days.
5A. Volume of waste produced
Feces & urine production in gal. / day per 135 lb. ALW = 1.37
Volume = 78,000 lbs. ALW / 135 lbs. ALW * 1.37 gal/day * 180 days
Volume = 142,480 Gals. or 19,048 Cu. Ft.
5B. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume = 0.0 Gallons / day * 180 days storage / 7.48 gal per CF
1.50
Volume = 0.0 Cubic Feet

John R. Lenfestey,,P.E. Castle Hayne, North Carolina
Operator: Mike Rabon #3 County: Duplin Date: 11/20/95
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall _ 7.00 Inches
Volume = 7.00 In. * DA / 12 Inches per Foot
Volume 14,583 Cubic Feet
5D. Volume of 25 year - 24 hour storm
Volume = 7.50- In. * DA / 12 Inches per Foot
Volume = 15,625 Cubic Feet
TOTAL REQUIRED TEMPORARY STORAGE
5A.
19,048
Cubic Feet
5B.
0
Cubic Feet
5C.
14,583
Cubic Feet
5D.
15,625
Cubic Feet
TOTAL
49,256
Cubic Feet

John R. Lenfestey,,P.E.
Operator: Mike Rabon #3
6. SUMMARY
Castle Hare, North Carolina
County: Duplin
Temporary Storage Period: __---_----__>
Rainfall in Excess of Evaporation: =—_—=====--=>
25 Year - 24 Hour Rainfall: -------------==>
Freeboard Height: -.---- ---_— -->
Side Slopes (Inside Lagoon):
Inside Top Length: _--------- __>
Inside Top Width: --- -- >
Top of Dike Elevation: ---- --->
Bottom of Lagoon Elevation: ------- =>
Total Required- Minimum Volume: ---------__>
Actual Design Volume:
Seasonal High Watertable Elevation(SHW1):===_>
Stop Pumping elevation:
Must be > or = to the SHWT elev.:
Must be > or = to min. req. treatment el.:
Required Minimum Treatment Volume:
Volume at Stop Pumping Elevation:
Start Pumping Elevation:
Must Be at Bottom of Freeboard & 25 Yr. Rainfall:
Actual Volume Less 25 Yr.- 24 Hr.-Rainfall: ---->
Volume at Start Pumping Elevation:
Date: 11 /20/95
180 Days
7.00 Inches
7.50 Inches
1.00 Feet
3.00 : 1
125.00 Feet
200.00 Feet
100.50 Feet
90.50 Feet
127,256 Cu. Ft:
140,463 Cu. Ft.
96.50
Feet
96.60
Feet
96.50
Feet
96.50
Feet
78,000 Cu. Ft.
81,118 Cu. Ft.
98.40 Feet "
124,838 Cu. Ft.
116,189 Cu. Ft.
Required Volume to be Pumped: ----___--__ _> 33,631 Cu. Ft. '
Actual Volume Planned to be Pumped: ___-> 35,071 Cu. Ft.
Min. Thickness of Soil Liner When Required:====> 11,4 46 Feet
,.•�H CAR
,♦ Cl
•''MESS/' i2.
7. Designed By: John Lenfestey, P.E. Approved B = SEA
DATE: DATE: • : �, �/Z
NOTE: SEE ATTACHED WASTE UTILIZATION P'' ,,�IeLEH�ES.••`�
COMMENTS:

'�'\ / [D�^�'..��y ; 1'�C 1.� ��r. �� }�'�• I+n�_,o ... I } '�l.' `t'•,. \.n. •.I aP4�% +�
pr!
I a
IP
-
Il° 'Y�`�l —'1 n rats" I •�
\l ,` � r ~ �' ,,,. � � ��� ` J./ f • 11 r . � - p ° � � 1 �I -��p�p Pp�¢� 5 j� � - f
1 Qy f u I Ilk
' n CO �' ` I J 1 I I
h
�•jf1�Qv/4 e
AIL G`°' �7s,�, m•�- � sF •♦ � �- �- �� �l _ �,. 'r '
10

1�ti. .L y. ,,
�`�+r,`���`'';��1�i,.'t•
Y •�
'lI:L:�•l k.t• .. 1 .. i ill '.
. !' `�
;�
'-...h•. ...{3: �. .L. •.
_"}�tis:
:'
' _
.'-i
_, ' `
��:1,'L+`•�V • :f ,l,•
:.
rl . i l;
r r�
1
,
'
Zr
Ir
f i• M . �./ C.; � ? .r �� . • V'1 �:.t,j '�F `S �.r.tr'�,i ,�. J 'Ij .
-yr.
i +''i 'h5 ['`.a y r� -`• .y1 .) f �;...•'K1_ p' !' �'r+t , }„`f i ww• �'
.SmA way,
„ _: :gr'.F.',' ; J I� L `3-ri;'•Nr 1 �1 r�k y (` + . a-J �C'
fLrNXOw
1RE �;.�. �• • � "� \�� `*
'-�`'Y.? i SaSr a i,�y♦� Z �ti ���.� /1 ,� `:.. L� ! �) \,4 :' 411
�, � a, i'L` -5�.� \' '•� to-. � �ii ,w ��`�, ` 'eKMw��
w
.t tj
�1k
� ,ti�,r-., � t 'pi•� ti '� �{W
a1.`. 1� �.] P'"�� �•' /, j'• .51Y -Qh
a. ( %`"�'Ly' L T s, .1."`a' ,.r•:i
• � :\ �f ` ` k. � l' � tiff - r�
} .t.� ; � •: • � ±:, "; � \ :i { ... �� ' J - • , � ''fir _ !•1'...•'t�, : j., . R,r• f �.��,$
i` 1 .,. �+� � r�! �� '�.}� J c?) ��*p�-��. - M � • '6iF,4 i r ' s '� !'j���•�e, t�:
.• �_ "� .. ,. � Ci �:d ���h"� S' •MIL" .,.�{.'+rl.� w S ��:e r4' ` ��, .;�,', .,

•l'fi, r�r't Y ��# r +r y;`it,. ,. �� '{ ' `\ Q =}{•{ , "''tXL+` t '.+ ,r;, I,t
+' -d�' �, u � �.;'h emu:: � ,,:• �r.
(/•1��. •' S,� ,`�� ��Y•�•r.. rtr� `p;'�j'i K t .� 3.1 y�,F �.,1. OY� :! r',t T '�' 'K.
' :il +.l• ,3:`'.�i�`• 4 l�` i� 7 :�, \ 3 r 1 L•' I •2 M .f.�= ,•fis'r' y+h '�+i�i
�.[} +k � ra �' _,,,� TEi '� �,`�'"•vi-j�•y,'� :.� a `.��'` fry � r' ! 1 • y' ytir - ' Q 11 'Yi a}�,; '' „ ;��t
Ali,
1'•-Lt ��G fi � `—Y��••�i �1}"', .1,,d� '�[r.J
�p , . � � �d+: - � - � u�.' p �� ,a.. �'' . " '•>,: t =•�.R �;R.. t ati'� � u' C. ar,':• 1 ` � •f �;.
y F� � �'s ' o .cii -�•.!, '. V*" �7 slS�i -et'S 1.1 ti,�.i't.
:d''.4r • :.'�;' ,. :. ay' • � ;� S ,. Z r '. : � ,q ���fIF 4 Pt ': �y 1' � � �� �� � � Jr ' All, ,,,, '; : • 4 �! :a' 'y�7 ;4 +•'f Y , [• �'S•� ,4i 1.' • "`J ,jy t' •}X'
l+' �� :3�. R- �A' �• .. �.�,r t {'; a � '1%•Y�^SR rinY• �' � "'y -1 i::f:1 .•���r �•r Y{�x7
.,_ •dri'iN-- ,ti ` S f ,; ,� *re L� N t. �� a~' o ' � � �'� +�i ��r � :� , ., .
f ~ ,1 •� .1� ; u'.,; •L,. '"` •11i��i'1'1+5'f " ro "� }.'�. �; N.- •j,. 't'''�f y�•i '. t f`.[
�•'' 1 '�d•'� `r^rr' t r - �. Mtn � �ky �' aY,;�' +,y r' .,i f :K�.
44.
Owl
v i'1���+` �Lc�1y7,: � ���...` ,. J1�ii ��Jb �``. � � �y�il�•/.! y' o �, d].1 4�i•':
-'�:., � 'l•rt..a t3 '•• � '�,." 3r 2 '``,. , r .' � • O .r�� 45 .Ji �'-+T-+; �'F. .rr/:�I ,:r '
} rt. •i• •_ i�1�� `�' � � �` � , Q' .s•�.�- i;y.'. d .1 jig a,La
1 `t it �� :: ti'. � °},. 'r.l•fti Z y f � ... � {r r ti '` 1 tir
"t i.�� `,��s. z :(f'," tir y� .i� ,�yq± •.} �,7, . ;'} T,
�3 �'�k,
,f !� ' r�.y. {r=. �' ' =•Fi.`r _' y �": +�' W v°� �+ i • �. t • r: .;s i+t 1 � r �+�� 4 `�v{ y+,` •.,'- '+%' , j•:'} � ,
��1• �y:'��� tirr'a• .f '•r.: ,: �4 iy i � r :Q 1 { t, iv 'N 4r r Q`�<z."�-,, .. ''p.,.
� !. -,��r {,.• y *.r,y1 �"r.F 1 ••!er..f' 1•,"lr ��i �'rt. C ;4-' 4,a, '� .,+d'' r 1, ..�d•- �� L 4;.
,yy r , �' ''� . ,,,. r& q l ' 1y�` •Ek •• 'h' " � y G ' r tii:J.i F":�� - � _ : i , Jf
•!� • �`�'' rn,, �r' • � 'r.� "ty, �t:Wr�'dy' S �' � ;Z„� '1` '. r• `� l>. ^ ;, ar r�."j' , '� / 'k'' ^: i.'x- 4.
,`:aTF� i V i - `'s'4 � ♦1 � 4, �,;" 1;..{..p�': ,, �, y F +: 0 e:', k+'. r � Q � r
_ �t�w�•.1 1' A � � l � ii � �r ,'� �"' t FY" ,wi h•r p ••� Y: f.
f / y rl � 1' fr;: � � Jy� 1. 1.=r ,(•t -_ M1,�, ..l �,'S. t p +fi
�•'Y e y�„L+`'y}r. 1 5fl i � r,p � �->""„t � �{•ts�+a' i�,M i •0 4 � Q.
.ip�4" - - •NIA w J� � A�' '��'• �1 iV y� `" � , 3,,; 1 � � n- �„
-Z r�
��}-� �.��� }� �f', `�f o. � {�'' �'t �,•�1'� �' �' kl�,�V• Za T[i�*�M'+ � � `'. �;4 4�
,.�� ,r���+.�, f �:�'�ss�' Er 1., 1 { L -,1`x• r � �r.. r.;- ��'''�:'� � .v-
: 4, y. `, y+' r� ter, ry y.• .4+F t'� 4• '! r
y� .� , ,ti c � t f'^•' rr`r i ti'[6' � 3 L ,,,,, %�,!�' r � m r+
rat ,�/�;';"+•r�r , POO 09
Y
Ld,y
.s � Y �,�''iFi•a4 - T�.i ,I •J+•,,•�L'1 �F.1� iw �.'. 'i .�.- rt. //: .}rNAc ryti:•t
l A
i• �� ,y ir1 '��f ti �'�4�. r yr�'./i�stifi:' :ti.,vs�, ..:
1 �{� °YF.%yeLrtNi
� i ,� r v � r S .i•. '�r. t� 'thq ;- 1 t� , s.A.x, ,-ti � !•t rx=,y, r 1 +,• r}r� ts,u �, },�� a rly y.,, 1<J iS � �+ ,r, 'is 1r- �a •�'�- iD 4^�PirF.to
.5r,-, „r'� i4.:,K.t.r � l,i;i#J''.�S�L*,Olt' 1!�i�,$ r">ti'" K�;,�i� ��� i �a. Ft�: � � �I'�f -, 1ig+�''4{�0 �i ��r• l�ktd,

SOIL INVESTIGATION TO DETERMINE SUITABILITY OF PROPOSED POND SITE
FARMER'S NAME M cLa Ell G Av, &'' DISTRICT '
DATE- COUNTY
.i
S. C. S. PHOTO SHEET NO. WORK UNIT
WATERSHED AREA MEASUREMENTS
CROPLAND ACRES PASTURE ACRES
WOODLAND ACRES TOTAL ACRES POND CLASS WORK UNIT CONSERVATIONIST
SKETCH OF PROPOSED'POND SHOWING WHERE. BORINGS WERE MADE (Approx- ecaie I feet)
Locate refcrcncc point m ccnlcr lint of darn and ldenlify on skctrh
■■■
■■■■■■■■■■■■■■■■■■■■■■■
■■N
■■■■■■■■■■■■■■■■■■■■■■■
■■■■■■■■■■■■
■■■e■■■■■■■■■■
■■■■■■■■■■■■
■■■■■■■■■■■■■
■■■■■■■I■■cs■l■■■■■■■■■■■■■■■
■■■■■IMEMENI■■■■■■■■■■■■■■
■
■■■N�
■m■►'
■■■■■■■■■■■■■■
■■■■■■■■■■■■■■■■■■■■■■■■■
■■■■■■■■■■■■■■■■■■■■■■■■■
■■■■■■■■■■■■■■■■■■■■■■■■■■
s
��li■I■I■i■i■1■1■
®I■!■I■[■1■I■I■1■1■'■I■1■1■!■
�l�i■I■I■I■1■�■1
!�I■!■1■1■I■I■i■I■I■I■1■I■1■1■
��I�l�l■■I■i■I■
®f
■1■1■I■1■I■1■1■[■�■I■!■[■I■
BORINGS MADE BY u 0 SIGNATURE & TI=

Mahn R: Lenfestey,. P-E. Page 1
508 Florence Drive
Castle Hayne, NC 28429
Farm Operator: Mike Rabon #3
Date: 11 /20/95
OPERATION AND MAINTENANCE PLAN
This lagoon is designed for waste treatment (permanent storage) with minimum
odor control. The time required for the planned fluid level to be reached
(permanent + temporary storage) may vary due to soil conditions, flushing
operations, and the amount of fresh water added to the system.
The designed 6 months temporary storage is an estimated volume based on:
1) waste from animals
2) excess rainfall after evaporation
and 3) the largest 24 hour (one day) rainfall that occurs on the average
of once every 25 years.
The volume of waste generated from a given number of animals will be fairly
constant throughout the year and from year to year.
This estimate is based on 7.00 inches of excess rainfall which is equal
to or exceeds the highest.6 months excess in a year. The average annual excess
rainfall is approximately 8 inches. Therefore, an average of 8 inches of excess
rainfall will need to be pumped each year. The 25 year rainfall will not be a
factor to consider in an annual pumping cycle, but this storage volume must
always be available. A maximum elevation is determined in each design to begin
pumping and this is usually the outlet invert of pipe(s) from the building(s).
If the outlet pipe is not installed on the elevation to begin pumping, a
permanent marker must be installed on this elevation to indicate when pumping
should begin. An elevation must be established to stop pumping to maintain the
minimum treatment depth of 6 feet.
Pumping can be started or stopped at any time between these two elevations
for operating convenience as site conditions permit, such as weather, soils,
crop, and equipment in order to apply waste without runoff or leaching.
Land application of waste water is recognized as an acceptable method of
disposal. Methods of application include solid set, center pivot guns and
traveling gun irrigation. Care should be taken when applying waste to
prevent damage to crops.

John R. Lenfestey, P.E. Page 2
508 Florence Drive
Castle Hayne, NC 28429
Farm Operator: Mike Rabon #3
OPERATION AND MAINTENANCE PLAN (continued)
The following items are to be carried out:
It is strongly recommended that the treatment lagoon be precharged to 1/2
of its capacity to prevent excessive odors during start-up. Precharging
reduces the concentration of the initial waste entering the lagoon, thereby
reducing odors. Solids should be covered with effluent at all times. When
precharging is complete, flush buildings with recycled lagoon liquid. Fresh water
should not be used for flushing after initial filling.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see attachment)
before land application.
3. Begin pump -out of the lagoon when fluid level reaches elevation 98.40 feet
as marked by the permanent marker.
Stop pump -out of the lagoon when fluid level reaches elevation 96.60 feet
or before the fluid depth is less than 6.10 feet deep (this prevents
the loss of favorable bacteria).
The designed temporary storage volume less the 25 year - 24 hour
storm volume is 33,631 cubic feet or 251,563 gallons.
As stated before, this volume will vary considerably from year to. year.
4. The recommended maximum amount to apply per irrigation is one (1) inch
and the recommended maximum application rate is 0.3 inches per hour.
5. Keep vegetation on the embankment and areas adjacent to the lagoon mowed
annually. Vegetation should be fertilized as needed to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable outlets.
8. Keep a minimum of 25 feet of grass vegetated buffer around waste utilization
fields adjacent to perennial streams. Waste will not be applied in open ditches.
Do not pump within 200 feet of a residence or within 100 feet of a well.
9. The Clean Water Act of 1977 prohibits the discharge of pollutants into waters
of the United States. The Department of Environment, Health and Natural
Resources, Division of Environmental Management, has the responsibility
for enforcing this law.

John R. Lenfestey, P.E. Page 1
508 Florence Drive
Castle Hayne, NC 28429
Farm Operator: Mike Rabon #3
Date: 11 /20/95
SPECIFICATIONS FOR CONSTRUCTION OF WASTE TREATMENT LAGOONS
SECTION 1: CLEARING
All trees and brush shall be removed from the construction area before any
excavation or fill is started. Stumps will be removed within the area of the
foundation of the embankment, all fill areas and all excavated areas.
All stumps and roots exceeding one (1) inch in diameter shall be removed
to a minimum depth of one (1) foot below final grade. Satisfactory disposition
will be made of all debris.
The foundation area shall be loosened thoroughly before placement of
the embankment material. The lagoon site (and pad site if needed) is to be
stripped of topsoil (minimum of 3") and stockpiled for use on dike and pad
slopes (finished depth of 2-3").
SECTION 2: CUT-OFF TRENCH
A cut-off trench (when specified) shall be installed as shown on the plans.
SECTION 3: CONSTRUCTION
Construction of excavated and earthfill areas shall be performed to the neat lines
and grades as shown on the drawings. Deviations from this will require prior approval
of Quarter M Farms and/or the SCS. Earthfill shall be placed in a maximum of 6" lifts
and shall not be placed in standing water. Compaction shall be performed by the
construction equipment or by a sheeps-foot roller, or other equivalent methods
approved by the Engineer.
The embankment of the lagoon shall be installed using the more impervious
materials. Construction of fill heights shall include twenty (20) percent overage
for compaction and settlement.

John R. Lenfestey,• P.E. l }
508 Florence Drive
Castle Hayne, NC 28429
Farm Operator: Mike Rabon #3
Date: 11 /20/95
SPECIFICATIONS FOR CONSTRUCTION (Continued)
To protect against seepage, when areas of unsuitable material are
encountered, they will need to be excavated to a minimum of one (1) foot
below grade and backfilled and compacted with a SCS approved material
{ie - CL, SC, CH). Refer to the soil investigation- information in the plans
::for special considerations. Precautions should betaken during construction
=.' to prevent excessive erosion and sedimentation.
SECTION 4: VEGETATION
All exposed embankment and other bare constructed areas shall be seeded
to the planned type of vegetation as soon as possible after construction
according to seeding specifications sheet.
Page 2

John R: Lenfestey; P.E. }
508 Florence Drive
Castle Hayne, NC 28429
Farm Operator: Mice Rabon #3
Date: 11 /20/95
SEEDING RECOMMENDATIONS
----------------
Acres of Fescue Grass:
0.0
Acres of Bahia Grass:
0.0
Acres of Hulled Bermuda Grass:
0.0
Acres of Rye Grain:
2.0
Acres of Rye Grass (Temporary vegetation):
2.0
Total Area to be seeded:
2.0 ' Acres
Use the following seed mixtures indicated:
0.0 Lbs. Fescue Grass @ 60 Lbs./Acre
(Best sdited.on clayey or wet soil conditions)
Seeding Dates: September 15 To November 30
0.0 Lbs. 'Pensacola' Bahia Grass @ 60 Lbs./Acre
(See Footnote No. 1)
Seeding Dates: March 15 to June 30
0.0 Lbs. Hulled Bermuda Grass @ 8 Lbs./Acre
(Suited for most soil conditions)
Seeding Dates: April 1 to July 31
60.0 Lbs. Rye Grain @ 30 Lbs./Acre (Nursery for Fescue)
80.0 Lbs. Rye Grass @ 40 Lbs./Acre (Temporary Vegetation)
Seeding Dates: December 1 to March 30
140.0 Total Lbs. seed mixture are required for this application
Page 1

John R. Lenfestey,•P.i~.
508 Florence Drive
Castle Hayne, NC 28429
Farm Operator: Mike Rabon #3
Date: 11 /20/95
SEEDING RECOMMENDATIONS (Continued)
Apply the following to the seeded area:
2,000.0 Lbs. of 10-10-10 Fertilizer @ 1000 LbsJAcre
4.0 Tons.of Dolomitic Lime @ 2 Tons/Acre
200.0 Bales of small grain straw @ 100 Bales/Acre
1 Page 2
All surface drains should be installed prior to seeding. Shape all disturbed
areas immediately after earth moving is completed.
Apply lime and fertilizer, then disk to prepare a 3 to 4 inch smooth seedbed.
Apply seed and firm seedbed with a cultipacker or similar equipment.
Apply mulch and secure with a mulch anchoring tool or netting.
Note 1: Pensacola Bahia Grass is slower to establish than common berm uda
grass. When using Bahia, it is recommended that 8 Lbs./Acre
of common Bermuda be included to provide cover until the
Bahia Grass is established.

WASTE UTILIZATION P3 PAGE 1
October 27, 1995
• PRODUCER: MICHEAL C. RABON
LOCATION: 446 NC 50 & US 117
WARSAW NC 28398
TELEPHONE: [phone]
TYPE OPERATION: Wean to Feeder Swine
NUMBER OF -ANIMALS: 5200 pigs design capacity
The waste from your animal facility must be land applied at a-ipecified
rate to prevent pollution of st.rfacv and/or groune;:ater. The pant
nutrients in the animal waste should be used to reduce the amc,unt of
commercial fertilizer required for the crops in the fields where waste
is to be applied. This waste utilization plan uses nitrogen as the
limiting nutrient. Waste should be analyzed before each application
cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for -realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner. Always
apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. -Do not apply more nitrogen than the crop can
utilize. Soil types are important as they have different infilitration
rates, leaching potentials, cation exchange capacities, and available
water holding capacities. Normally waste shall not be applied to land
eroding at greater than 5 .ton. ',per acre per year. With speci:., pre-
cautions, waste may be aDplie. to land eroding at -it) to 10 tor_ per
acre per year. Do not apply v.-ste on saturated soils, when it is
raining, or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed under DEM
regulations. Wind conditions should also be considered to avoid drift
and downwind odor problems. To maximize the value of the nutrients
for crop production and to reduce the potential for pollution, the
waste should be applied to a growing crop or applied to bare ground
not more than 30 days prior to planting. Injecting the waste or
disking will conserve_ nutrients and reduce odor problems.
This plan is based on waste application through irrigation for this
is the manner in which you have chosen to apply your waste. If you
choose to inject the waste in the future, you need to revise this
plan. Nutrient levels for injecting waste and irrigating waste are
not the same.
The estimated acres needed to apply the animal was;-e is based ,n
typical nutrient content for ..his type of facility. Acreage require-
ments should be based on the •-:dste analysis report from your waste
management facility. Attached you will find information on proper
sampling techniques, preparation, and transfer of waste samples to
the lab for analysis.
This waste utilization plan, if carried out, meets the requirements
for compliance with 15A NCAC 2H.0217 adopted by the Environmental
Management Commission.

WASTE UTILIZATION PLT PAGE 2
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
5200' pigs x .40 tons waste/pigs/year = 2080 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
5200 pigs x .48 lbs PAN/pigs/year = 2496 lbs. PAN/year
Applying the above amount of waste is a big job. You should plan time
and have appropriate equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
TABLE It ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & CLASS--
CROP
YIELD
LBS
COMM N
**
* LEIS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW
PER AC
.AC
USED
APPLIC.
TIME
435
2
NOB
BP
4.6
230
9.63
2214.9
APR-SEP
435 1-2 1 SG 1 150 1 19.63 1481.5
SEP-NOV
END
TOTAL 2696.4
-- Indicates that this field is being overseeded (i.e. interplanted)
or winter annuals follow summer annuals.
NOTE: The applicator is cautioned that P and K may be over applied
while meeting the N requirments. Beginning in 1996 the Coastal Zone
Management Act will require farmers in some eastern counties of NC to
have a nutrient management plan that addresses all nutrients. This
plan only addresses Nitrogen.

WASTE UTILIZATION PL.r"
PAGE 3
TABLE 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate
land. See required specification 2.)
TRACT
FIELD
I SOIL TYPE & CLASS--
CROP
YIELD
LBS
ICOMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW
PER AC
AC
USED
APPLIC
TIME
END
TOTAL 10
indicates that this field is being overseeded (i.e. interplanted)
or winter annuals follow summer annuals.
In interplanted fields (i.e. small grain, etc, interseeded
in bermudagrass), forage must be removed through grazing,
hay and/or silage. Where grazing, plants should be grazed
when they reach.a height of six to nine inches. Cattle
should be removed when plants are grazed to a height of four
inches. In fields where small grain, etc, is to be removed
for hay or silage, care should be exercised riot to let small
grain reach.maturity, especially late in the season .(i.e.
April or May). Shading may result if small grain gets too
high and this will definitely interfere with the stand of
bermudagrass. This loss of stand will result in reduced
yields and less nitrogen being utilized. Rather than
cutting small grain for hay or silage just before heading as
is the normal situation, you are encouraged to cut the small
grain earlier. You niay want to consider harvesting hay or
silage two to three times during the season, depending on
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late
September or early October. Drilling is recommended over
broadcasting. Bermudagrass should be grazed or mowed to a
height of about two inches before drilling for best results.
Acreage figures may exceed total acreage in fields due to
overseeding.'
** lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.

} WASTE UTILIZATION PI j PAGE 4
The following legend explains the crop codes used in tables 1. and 2 above:
LBS N
CROP CODE
CROP
UNITS
PER UNIT
BP
HYBRID BERMUDAGRASS--PASTURE
TONS
50
SG
SMALL GRAIN OVERSEEDED
AC
50
TABLE 1
TABLE 2
TOTAL
TOTALS FROM TABLES 1 AND 2
f 9.63 1 2696.4
9.63 1 2696.4
AMOUNT OF N PRODUCE51 2496
*** BALANCE ( -200.4
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.
Acres shown in each ofthepreceding tables are considered to be the
usable acres excluding required buffers, filter strips along ditches,
odd areas unable to -be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual. total
acres in the fields listed may, and most likely will be, more than
the acres shown in the tables.
NOTE: The Waste Utilization Plan must contain provisions for periodic
land application of sludge at agronomic rates. The sludge will be
nutrient rich and will require precautionary measures to prevent
over application of nutrients or other elements. Your production
facility will produce approximately 395.2 pounds of plant
available nitrogen (PAN) per year in the sludge that will need to be
removed on a periodic basis. l-his figure is PAN when broadcasting
the sludge. Please be aware that additional acres of land, as well
special equipment, may be needed when you remove this sludge.

? WASTE UTILIZATION P' i
PAGE 5
See attached map shoeing the fields to be used for.the utilization of
waste water.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of
the soil at the time of irrigation such that runoff or ponding occurs.
This.rate is limited by initial soil moisture content, soil structure,
soil texture, water droplet size, and organic solids. The application
amount should not exceed the available water holding capacity of the ;
soil at the time of irrigation nor should the -plant available nitrogen
applied exceed the nitrogen needs of the crop.
Your facility.is designed for 180 days of temporary storage
and the temporary storage must be removed on the average of once every
6 months. In no instance should the volume of waste being stored in
your structure be within 1.7 feet of the top of the dike.
If surface irrigation is the method of land application for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables 1 and 2. Failure to apply the recommended rates and
amounts of Nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report
for assistance in determining the amount of waste per acre and the proper
application rate prior to applying the waste.
NARRATIVE OF OPERATION:

WASTE UTILIZATION PL: PAGE 6
Flans and Specifications
1. Animal waste shall not reach surface waters of the state by runoff,
drift, manmade conveyances, direct application, or direct discharge
during operation or land application. Any discharge of waste which
reaches surface water is prohibited. Illegal discharges are subject
to assessment of civil penalties of $10,000 per day by the Division
of Environmental Management for every day the discharge continues.
2. The Field Office must have documentation in the design folder that
the producer either has owns or has long term access to adequate
land to properly dispose of waste. If the producer does not own
adequate land to properly dispose of waste, he shall provide MRCS
with a copy of a written agreement with a landowner who is within
a reasonable proximity, allowing him/her the use of the land for
waste application for the life expectancy of the production
facility. It is the responsibility of the owner of the facility
to secure an update of the Waste Utilization Plan when there is
a change in the operation, increase in the number of animals,
method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
Nitrogen needs.for realistic crop yields based on soil type,
available moisture, historical data, climate conditions, and
level of management, unless there are regulations that
restrict the rate of application for other nutrients_
4. Animal waste may be applied to land that has a Resource
Management System (RMS) or an Alternative Conservation System
(ACS). If an ACS is used the soil loss shall be no greater
than 10 tons per acre per year and appropriate filter 'strips
will be used where runoff leaves the field. These filter
strips will be in addition to "Buffers" required by DEM.
(See FOTG Standard 393 - Filter Strips and Standard 390
Interim Riparian Forest Buf-ers).
5. Odors can be reduced by injecting the waste or disking after
.waste application. Waste should not be applied when the
wind is blowing.
6. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally
tilled cropland. When applied to conservation tilled crops
or grassland, the waste may be broadcast provided the
application does not occur during a season prone to
flooding. (See "Weather and Climate in North Carolina" in
the NRCS Technical Reference - Environment file for guidance.
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or
to surface waters and in a -method which does not cause drift
from the site during application. No ponding should occur
in order to control conditions conducive to odor or flies
and to provide uniformity of application.
Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
Animal waste shall be applied on actively growing crops in
such a manner that no more than 20 to 25 percent of the leaf
area'is covered_

1 WASTE UTILIZATION PLR''. PAGE 7
10. Waste nutrients sue_ .11 not be applied in fall; _' winter for
spring planted crops -on soils with a high potential for
leaching. Waste nutrient loading rates on these soils
should be held to a minimum and a suitable winter cover
crop planted to take up released nutrients. Waste shall
:.y not be applied more than 30 days prior to planting of a
crop on bare soil.
11. Animal waste shall not be applied closer than 25 feet to
surface water. This distance may be reduced for waters that
are not perennial provided adequate vegetative filter strips
are present. (See Standard 393 - Filter Strips)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of !
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other
property and public right -of ways.
15. Animal waste shall not be discharged into surface wasters,
drainageways, or wetlands by discharge or by over -spraying.
Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site
by a "technical specialist". Animal waste should not be
applied on grassed waterways that discharge into water
courses, except when applied at agronomic rates and the
application causes no runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into
the animal waste management system.
17. Lagoons and other uncovered waste containment structures
must maintain a maximum operating level to provide adequate
storage for a 25-year, 24-hour storm event in addition to
one (1) foot mandatory freeboard.
18. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments,
berms, pipe runs, etc.). If needed, special vegetation
shall be provided for these areas and shall be fenced, as
necessary, to protect the vegetation. Vegetation such as
trees, shrubs, and other woody species, etc. are limited to
areas where considered appropriate. Lagoon areas should be
kept mowed and accessible. Lagoon berms and structures
should be inspected regularly for evidence of erosion, .leakage
or discharge.
19. If animal production at the facility is to be suspended or
terminated, the owner is re,ponsibie for obtaining and imple-
menting a "closure plan" which will eliminate the possibility
of an illegal discharge, pollution and erosion.
20. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept
on site.

WASTE UTILIZATION PLP- PAGE 8
`-J
NAME OF FARM:
OWNER / MANAGER AGREEMENT
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the ap-
proved animal waste utilization plan for the farm - named above. I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or 'construction of new facilities
will require a new certification to be submitted to the Division of
Environmental Management (DEM) before the new animals are stocked. I
(we) also understand that there must be no discharge of animal waste
from this system to surface waters of the state from a storm event
less severe than the 25 year, 24 hour storm. The approved plan will
be f iled on -site at -the farm office and at the office of the local
Soil and Water Conservation District and will be available for review
by DEM upon request.
I (we) understand that I must own or have access to equipment,
primarily irrigation equipment, to land apply the animal waste
described in this waste utilization plan. This equipment must be
available at the appropriate pumping time such that no discharge
occurs from the lagoon in a 25-year 1-day storm event. I also cer=
tify that the waste will be applied on the land according to this
plan at the appropriate times and at rates that no runoff occurs.
NAME OF FACILITY OWNER: MI,CHEAL C. RABON
SIGNATURE�,4,"Me , V, I -
C _i& �a�E: e
NAME OF MANAGER (if different from owner) :
please print
SIGNATURE:
DATE:
NAME OF TECHNICAL SPECIALIST: Billy W_ Houston
AFFILIATION: Duplin Soil and Water Conservation
ADDRESS (AGENCY): P. 0. Box 277
Kenansville NC 28349
S IGNATURE : - DATE: 11-- 6 --`t L

<.t�.:-• � :�. :�,`!s„t,� 'A�,sJLr`r'1�.,�'•`t;"• ...'[,y'r.' fr;. '7;l `.f - -y —^ Q, \J �y 'U �•: � r ,,.,_ �,.�lr. rt,w_ r.
,i.`�, [�' ,•+! i+ �� Yyoe� - �;r.� ,�\ Cr �'"t�� � � '� +� �.
��.. l+4 tl'''T... .' � ��, �� �t � ftti•- � Q.�. [.� .'yam ..t_ [, •� ., �i'
� � .Lr .-r'•. •� !;'.ti �"��... i' �. "[ ti •�' aYS',l`s�'T4 a"' ," I"'!y!i� �jC �' It �'1,. tiv '^ .'9t�
��. i .,. f��a�•�', }sy�.#�, � s ,j r D rn� , 0' r ..vr L }R� N �s`G't�'tS;�•!: � ei : �.V ' r �''�1!. � fd 4r� ,'�°,.��,��
�'..�y�. ? � h ', ';hv ...f , '�'s 1 � 17 'Z � >;�i.A`!� '�rl tii„ P: � �� '';� '�.�rq��' ",, Ir�e�a:i''{•L! ij �9"i' ���,L t �1i
y ��` ` Gz1 1. ., J,"F �i li M ^�.r � � .,. sN YS. ,�� W- .\ , � g. r y. [ � rF� L•{1 •� Y 1
�y; +i�t"',« i l {� :', {� '.'. `iLrt. CC� A ►��r ; , [ �y��. , r •F' ,4
/ •+`'. `s•, �`1[: f a .. !7;' +i1 tb 1l�wS. 'yr.r 0 \ \\l "�.� /�i'•,.' `1 .n'•„�
•�ifL{. V V 1 Yf q(1 '� r xS- 7` � � f „� Z �� � :', /,. -r0 - . � �} �'.
�.rr✓ tir'� ` �1 ice" � • �+N � ����} �??"���1� � S"^�- }: � , � j�C�� � + ':('} r `�r, f+N
�'�.. , S,S=,r''l �.. . ti 'i,',�. o'G d.' !j„ ' i• ,' �. ^ `? , �v��L+��C+.,'{��, ik`+' - � t', ,� 4 +:.� '�M � `F'a.'3�jC � 5 : ��:. a `
t n N .r ,'y ,' ". i} �, s�•.�� ram' ¢ >� , I[�,y�[�, .
- ` yd .. Y , ,,,y,+, j ; `xf ski _ `� ' ;;} ����+T.6'4�':, � .,., O .,''.il� 1 • '�
1 ,; � '�! ,1 �� µ + 1 A w `' r�•'' 1'rt y � Q• rip M ` � -ad'y' , � •�.: t ��,
4 �w'
IV
K ;�t .. .a„ ♦fJ}Cii �� F'',(p I: L4 ![Wti Z fIVS,,{
it. ~'i�.-, ' •eft �{:.? f ,'• �.'a ; �, .,8 ¢-s .0 �'b�� ? ✓ r 4�rL Q �.d• r..�ti
.i 'i: ) r<.V � � 'ii . � '� l� 7 l � I iy�� Y ' I f0 l .:r ' 4 O +•�
i�• Q► �~`�' �'.�! �?+k.� 1 ''� �•,n? + s�: �t i� �. �'v �,, r` 'i�� � r � �' rr't Tii � � ..��r r .It:�
1 r ' ,,rF�'r.,, r+�•;�.. }� 1 i V5 :+r�t ' . '���,/� [ , .d : ^d+� ! L��' 0. ,I , tkY ' ��, � � ��` ti��;,, '/ 1 1
;..f�- r ST 1" tr� 11F'�,' �{ � I - Q� ' r 4 r.� ti'•'.:' �'
-�r�r,• i' ,ry.�",, .. o'- �,, Its .."r , � , ; � �y �
+', ' � i fir' f •`7,,.... •.i . •i tf_1 JV, •�_ � L - �.�!•: ,.. y ' I � � ° '
.. _-,•y�'i[ 4• .� r ,' Z,V � �� idry [s+w �ti� ��
•� e ,r1�,'4• P�� �krr � r.,� � u :f• r t,x�'�� .� �� :x*i'4 rxet'fi��
,#� . � � "`h�K� .f` l .� r R �� 1 � D F ��I.irfili. y 1 Z.tiM •..}y>.+•' •i
.63
'!.. `, f � i �.L' v � "�� i �".3.�:iY�x � J t �I � '� ''•r. S''�� �`".5��1'`. � �4 Z.' i ;,�;.
'�' .+1 . f •. r. r•1{�` ',^i r� to
.:1 .4�„y '.�' �'1 ' � ' } i' ,i'i yt0•.a :fty, o-:'if•!-• "ra:r Ip�, �Ci�d'Y
Cl OC2 0J"
.• �..4, A
L�.� .+ �r �:'•�[� `Zxr'1 �a`,f����); J [� Y Yf' ���)[yyt, a,� t J �/.: ��r , � .„M ���ka�T
[ _ 1 m'r�' �n:l "',�{`r a 5 •}�c2},L �' � +ice ��� •�''
,k.
.A .

\ �� Ili ° 1( .1f � �� 55t •.� �,, .�•' �� •+N 5•�>.•'j��
, I
( fIl ° aar us�4� _/ � ,4`p�l � ' � �... his! • `'� ,\ • ,'u t'� `:
L�ti•. A
.. ,II � a �—\���' I' I 5 �•^ \� ' 444$ . 15 f� S' t II � � ..: � .�T'�1
+ � � , �•. o ,, ' a 'lit 1 (- m •p•. �� n i '� ' •� • � -� : � Ins 1 ` � it � I y
ra
h 8
®' VI?
��� t a •'it b r' ,•� i� 1 I f
� •r. to s\ � 1O �•,a�sF '• j /h � //- � �I. grj� II o
°o O W
m olU. .
N � i IL

t
SOIL INVES i iGATION TO DETERMINE SUITABILITY ,_ . PROPOSED POND SITE
FARMER'S NAME Ali DISTRICT
DATE 11 -- 7 -- q,5 - COUNTY
S. C. S. PHOTO SKEET NO. WORK UNIT
WATERSHED AREA MEASUREMENTS
CROPLAND ACRES PASTURE ACRES
WOODLAND ACRES TOTAL. ACRES POND CLASS WORK UNIT CONSERVATIONIST
SKETCH OF PROPOSED*POND SHOWING WHERE, BORINGS WERE MADE (Appro - acale 111= feet)
Locale reference point +n center line of darn and ldemdrfy on sksdcJ
M■MME■■■■■e■S■■■■M■■■EeO�e
SOMEONE
■M■MME■O■E■■■■MS■■
■■MM■■■E■■■■
MENIMMEMEEMMINE1
■ESE■E■le■EMI■■■E■■■■■■S■■■
im
ANN
ON.
■■■■■■■■■■■■E■
■■■■EE■■■O■■■■■■■■■M■OEM■
MESS■®■■■■SSSSSM■S■■■■■■■■
®�®1©ii�®i�i�l��lmiml©I®I®I®!mlmlm�mf�l®I:1�
�11,�J■1■I■J■J■1■1■®I■!e!■!■1■I■!■1■leJe!■I■1■1■
■�!�!■I■1EIEIEI
I
!�I■I■1■1■I■I■I■LEI■I■1■IEI■1■
®I�i■!■I■`■i■i�l�
®I■I■f
■f
■!■I■I■1■1■I■I■I■I■!■
�:1®i■i■1■i■i■'■1■�!�l■I■1■1■I■I■I■1■■I■1■1■i■
��[�I■I■I■I■I■1■!�!■1■1■1■1■ICI■f
■!■I■1■I■1■1■
��I�I■l�!EI■i■1■
■lid!■1■1EI■1■R■I■1■i■1■!■1■f
■
1��1'�I■1■!■t�l■1■,l.�ili�11■i■f■1■f■i■1■1■1■!■I■1■I■
�I■ill■I■I
I■!■�■III■E■i■I■1■lel■I■1■f■I■EMI■
�i■1■!�i■I■!■1■'
i■I■f■1■1■IEf■I■1■I■!■1■f■1■
!�!�'
�i■I�;■1■'■LE�!EI■I■i■AEI■I■!■1■i■I■iE10!■
�I
11
I
I
�
�
I
1
i
i
i■I■I■1
BORINGS MADE BY— l3gv k A a a SIGNATURE & TITLE
SM_Sc ( C L kJ,l

Revised April 20, 1999
JUSTIFICATION & DOCUMENTATION FOR MANDATORY WA DETERMINATION
Facility Number '2-99 Operation is flagged for a wettable
Farm Name: acre determination due to failure of
On -Site Representative: V -t Part 11 eligibility item(s) F1 F2 F3 F4
Inspector/Reviewer's Name:
Date of site visit: —d-C
Operation not required to secure WA
determination at this time based on
exemption E1 E2 E3 E4
Date of most recent WUP: � _'A Operation pended for wettable acre
AM Ak-0- determination based on P1 P2 P3 -
Annual farm PAN deficit: �a Mg' pounds
Irrigation System(s) - circle #: 11.. hard -hose traveler, 2. center -pivot system; 3. linear -move system;
4. stationary sprinkler system w/permanent pipe; 5. stationary sprinkler system w/portable pipe;
6. stationary gun system w/permanent pipe; 7. stationary gun system w/portable pipe
PART I. WA Determination Exemptions (Eligibility failure, Part 11, overrides Part I exemption.)
E1 Adequate irrigation design, including map depicting wettable acres, is complete
and signed by an I or PE.
E2 Adequate D, and D2/D3 irrigation operating parameter sheets, including map
depicting wettable acres, is complete and signed by an I or PE.
E3 Adequate D, irrigation operating parameter sheet, including ap depicting
wettable acres, is complete and signed by a WUP.
E4 75% rule exemption as verified in Part Ill. (NOTE:75 % exemption cannot be
applied to farms that fail the eligibility checklist in Part II. Complete eligibility
checklist, Part 11- F1 F2 F3, before completing computational table in Part 111).
PART H.75% Rule. Eligibility Checklist and -Documentation of WA Determination
Requirements. WA Determination .required .because -operation fails Wine of .the .eligibility - - -
requirernents listedbeiow:
F1 Lack -of :acreage -,which Tesulted in:over-applicationmf--wastewater�(PAN) onmprey.
fields) accordingfofarm'sdasttwoyearsaf-rmgafion-xecords.-:
F2 Unclear, -illegible, -or lack ofinformation/map.
F3 Obviousfield-limitations -{numerous Bitches;failtrrefo:deductTequired
bufferlsetback�acreage;-or25%--offotalacreageddentiiiedanMAWMP::includes: _
small; -irregularly -shaped fields =. fields:less#han�acresfortravelers or -less -than
2 acres-for.'staiionarysprinklers).
F4 WA determination required because CAWMP credits fi d r rm q el (s) s acreage rn excess
of 75% of the respective field's total acreage as noted in table in Part Ili.

Revised April 20, 1999
Facility Number -
Part Ill. Field by Field Determination of 75% Exemption Rule for WA Determination
TRACT
- .-FIELD
TYPE OF
TOTAL
CAWMP
FIELD
NUMBER
NUMBER'.2
IRRIGATION
ACRES
ACRES
%
ICOMMENTS3
SYSTEM
(X w-
TFq3 q�;)-
FIELD NUMBER' - hvdrant oull-zone- or�oint numbers Tnav be used in Glace of field numbers deoendino nn CAWMP
and type of irrigation system.- If pulls, etc. cross More -than one field,.inspectorlreviewer will have to combine fields to
calculate 75% field by field determination for exemption; otherwise operation will be subject to WA determination.
FIELD NUMBER2 - must be clearly delineated onmap.
COMMENTS' -back-up fields with'CAWMP acreage:exceeding75% of its total_acresand havingreceived less than 50%
of its annual PAN as documented in the farm's-previous.-two years' ('l997 8 1998) of irrigation zecords,--cannot serve -as -the
.sole basis -for requiring a WA Determ_inafion:_Back-up fields -must -be noted in the -comment section -and must be accessible
by irrigation system_
Part IV. Pending WA Determinations -
Pi Plan lacks -following information:
P2 Plantevision maysatisfy7.5% rule based on adequate overall PAN deficit -and by
adjusting -all field acreage:to below 75% use rate
P3 Other (iefin process of installing new irrigation system):

r��
State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
Kerr T. Stevens, Director
RABON NURSERY 1, 2 & 3
446 NC 50 & US 117
WARSAW NC 28398
Attn: Mike Rabon
Dear Mike Rabon:
RECEIVED
AUG 18 1999
BY:
August 16, 1999
M VW'A
/ • •
NCDENR
NORTH CAROUNA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Application No. AWS310297
Additional Information Request
Rabon Nursery 1, 2 & 3
Animal Waste Operation
Duplin County
The Nan -Discharge Permitting Unit has completed a preliminary engineering review of the subject application. Additional
information is required before we can continue our review. Please address the following by September 15, 1999:
1. Page 2 of the General Permit Application Form was not filled out completely. Please find the enclosed page
with the missing items highlighted. Please fill in the information and sign and date somewhere on the page.
2. Best Management Practices (BMPs) that are to be implemented at this facility should be identified (check
the appropriate BMPs) on the Insect Control Checklist, the Odor Control Checklist and the Mortality
Management Checklist_
3. Please provide the Emergency Action plan for this facility.
4. Field 2, Tract 435 is Iisted as having 9.6 acres in the Waste Utilization Plan (WUP) but on the maps
provided it is shown as a 3.7 acre field. Please explain this discrepancy or provide a map with the field and
proper acreage amount clearly labeled.
5. From the information submitted, it appears that there are at least two separate operations here. Sites 2 and 3
seem as though they share a common sprayfield but Site 1 seems to be separate from these and it doesn't
appear that any waste can be transferred between them or that they share any common sprayfields. Please
provide an explanation as to why these facilities are applying for one permit instead of at least two.
Please note that all WUP revisions must be signed and dated by both the owner and the technical specialist. Please
reference the subject permit application number when providing the requested information. All information should be signed,
sealed, and submitted in duplicate to my attention at the address below. The information requested by this letter must be
submitted on or before September 15, 1999 or the Division will return your application as incomplete in accordance with 15A
N.C.A.C. 211 .0200 and your facility will be considered to be operating without a permit.
1617 Mail Service Center, Raleigh, NC 27626-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Application No. 31-0297
Mike Rabon
Page 2
Please be advised that operation of the subject animal waste management system without a valid permit is a violation of North
Carolina General Statute 143-215.1 and will subject you to the enforcement authority of the Environmental Management
Commission.
If you have any questions regarding this request, please call me at [phone], extension 364.
Sincerely,
V_7VJWJO__5
Dianne Thomas
Soil Scientist
Non -Discharge Permitting Unit
cc�Wilmington.Regional•Office; Water-Qual
Permit File

State of North Carolina
Department of Environment,
Health and Natural Resources
James B. Hunt, Jr., Governor
Jonathan B.' Howes, Secretary
November 13, 1996
Mike Rabon
Turkey Swamp Nursery 2 & 3
446 NC 50 & US 117
Warsaw NC 28398
SUBJECT: Operator In Charge Designation
Facility: Turkey Swamp Nursery 2 & 3
Facility ID#: 31-297
Duplin County
Dear Mr. Rabon:
Senate Bill 1217, An Act to Implement Recommendations of the Blue Ribbon Study
Commission on Agricultural Waste, enacted by the 1996 North Carolina General Assembly,
requires a certified operator for each animal waste management system that serves 250 or more
swine by January 1, 1997. The owner of each animal waste management system must submit a
designation form to the Technical Assistance and Certification Group which designates an
Operator in Charge and is countersigned by the certified operator. The enclosed form must be
submitted by January 1, 1997 for all facilities in operation as of that date. Failure to designate a
certified operator for your animal waste management system is a violation of 15A NCAC 2H
.0224 and may result in the assessment of a civil penalty.
If you have questions concerning operator training or examinations for certification, please
contact your local North Carolina Cooperative Extension Service agent or our office.
Examinations have been offered on an on -going basis in many counties throughout the state for
the past several months and will continue to be offered through December 31, 1996.
Thank you for your cooperation. If you have any questions concerning this requirement please
call Beth Buffington or Barry Huneycutt of our staff at 919/733-0026.
Sincerely,
A. Preston Howard, Jr., P. ector
Division of Water Quality
Enclosure
cc: Wilmington Regional Office
Water Quality Files
P.O. Sox 27687,
Raleigh, North Carolina 27611-7687 C An Equal Opportunity/Atfirmative Action Employer
Voice 919-715-4100 50% recycled/10% post -consumer paper

- AND4AL WASTE MA! .GEMENT PLAN CERTIFICAT_:_ N FOR EXISTING FEEDLOTS
Please return the completed form to the Division of Environmental Management at the address on the
reverse side of this form. RECEIVED
Name of farm (Please print) : K ah u+n /V tars e r- y
Mailing Address: 44� ✓C so �
I_JAr rac.w /V G ag3 9R Phone No.:
Farm ocahon: Latitude and Longitude: Z ° o V ` Sa'' q$° _ o V s6 '' (required) . Al , please attach a
copy of a county road map with location id ne i ed.
Type of operation (swine, layer, dairy, etc.) : sw \ e.. - -- -
Design capacity (number of animals)a � O OQ rtu r s ervl _
Average size of operation (12 month population avg.):_
Average acreage needed for land application of waste (acres)
Technical Specialist Certification
As a technical specialist designated by the North Carolina Soil and Water Conservation Commission pursuant
to 15A NCAC 6F .0005, I certify that the existing animal waste management system for the farm named
above has an animal waste management plan that meets the operation and maintenance standards and
specifications of the Division of Environmental Management and the USDA - Soil Conservation Service
and/or the North Carolina Soil and Water Conservation Commission pursuant -to 15A NCAC 2H.0217 and
15A NCAC 6F .0001 - .0005. The following elements and their corresponding minimum criteria have been
verified by me or other designated technical specialists and are included in the plan as applicable: minimum
separations (buffers); adequate quantity and amount of land for waste utilization (or use of third party);
access or ownership of proper waste application equipment; schedule for timing of applications; application
rates; loading rates; and the control of the discharge of pollutants from stormwater runoff events less severe
than the 25 - year, 24 - hour storm.
X When checked, see reverse side of form for conditions/exceptions.
Name of Technical Specialist (Please Print): MICHAEL E. SUGG
Affiliation (Agency): Address (Agency): USDA NAT. RES. CONS. SERV.
Signature: _ �G , t la PO BOX 277 KENANS VILLE NC
TELEPHONE [phone]
O wner/Manager Agreement
I (we) understand the operation and maintenance procedures established in the approved animal waste
management plan for the farm named above and will implement these procedures. I (we) know that any
expansion to the existing design capacity of the waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the Division of Environmental Management
before the new animals are stocked. I (we) also understand that there must be no discharge of animal waste
from this system to surface waters of the state either directly through a man-made conveyance or through
runoff from a storm event less severe that the 25-year, 24-hour storm. The approved plan will be filed at the
farm and at the office of the local Soil and Water Conservation District.
Name of
Signature:
Name of
Signature: Date:_
Note-. A change in land ownership requires notification or a new certification (if the approved plan is changed) within 60days of a title transfer.
DEM USE ONLY: ACE#

9
0
I
y
I
'�

REGISTRATION FORM FOR ANIMAL FEEDLOT OPERATIONS
Department of Environment, Health and Natural Resoupces
Division of Environmental Management
Water Quality Section
If the animal waste management system for your feedlot op!A.M
4�tion
is designed to serve more than or equal to 100 . head of ca
horses 250 swine 1 000 shee ar 30 000 birds that are
p,
by a liquid waste system, then this form must be filled out and
mailed by December 31, 1993 pursuant to 15A NCAC 2H.0217 (c) in
order to be deemed permitted by DEM. Please print clearly.
Farm Name: Mike Rabon
Route 1 Box 20
Warsaw, NC 28398
Duplin County 919-293-7093(H)/293-7660(F)
Owner(s) Name:
Manager(s) Nam
Lessee Name:
Farm Location (Be as specific as possiblen oad names,,
direct' on, milepost, etc.) : lC�� _�1/ /.2 /nf ��[-
UZZY
Latitude/Longitude if known: QBSP # 15-143-19-06
Design capacity of animal waste management system (Number and
type of confined animal'(,6j':
Average animal population on the farm (Numb r and t pe of
animal (s) raised) :
Year Production Began: ASCS Tract No.:�
Type of Waste Management System Used: L O y✓
Acres Available for Land Application of W ste:
Owners) Signature(s):2" Date:
31- Qg-3-
Date:
(Carl Avery, Serviceman)

State of North Carolina
Department of Environment,
Health and Naturai resources
Division of Environmental Management
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
A. Preston Howard, Jr., P.E., Director
December 9, 1993
Michael Rabon
Rt. 1, Box 20
Warsaw NC 28398
Dear Mr. Rabon:
This is to inform you that your completed registration form required by the recently
modified nondischarge rule has been received by the Division of Environmental Management
(DEM), Water Quality Section.
On December 10, 1992 the Environmental Management Commission adopted a water
quality rule which governs animal waste management systems. The goal of the rule is for
animal operations to be' managed such that animal waste is not discharged to surface waters
of the state. The rule allows animal waste systems to be "deemed permitted" if certain
minimum criteria are met (15A NCAC 2H .0217). By submitting this registration you have
met one of the criteria for being deemed permitted.
We would like to remind you that existing feedlots which meet the size thresholds
listed in the rule, and any new or expanded feedlots constructed between February 1, 1993
and December 31, 1993 must submit a signed certification form to DEM by December 31,
1997. New or expanded feedlots constructed after December 31, 1993 must obtain signed
certification before animals are stocked on the farm. Certification of an approved animal
waste management plan can be obtained after the Soil and Water Conservation Commission
adopts rules later this year.
We appreciate you providing us with this information. If you have any question about
the new nondischarge rule, please contact David Harding at [phone].
Sincerely,
/A -Steve Tedder, Chief
Water Quality Section
P.O.. Box 29535, Raleigh, North Carolina 2762640535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper