310287_HISTORICAL_20171231

NORTH CAROLINA
Department of Environmental Qual

NCDENR
North Carolina Department of Environment and Natural Resources
Pat McCrory
Governor
Donnell Kornegay
Pleasant Grove Nursery
320 Scotts Store Road
Mt. Olive, NC 28365
Dear Donnell Komegay:
Donald R. van der Vaart
Secretary
February 12, 2015
Subject: Sludge Survey Testing Dates
Certificate of Coverage No. AWS310287
Pleasant Grove Nursery
Animal Waste Management System
Duplin County
The Division of Water Resources (Division) received your sludge survey information on
February 11, 2015. With the survey results, you requested an extension of the sludge survey
requirement for the lagoons at the Pleasant Grove Nursery facility. Due to the amount of
treatment volume available, the Division agrees that a sludge survey is not needed until 2019 for
your lagoons (PLG-1 and PLG-2).
The next sludge survey for the lagoons at Pleasant Grove nursery facility should be performed
before December 31, 2019.
Please call me at [phone] if you have any questions.
Sincerely,
J.R. Joshi
Animal Feeding Operations Program
Division of Water Resources
cc: Wilmington Regional Office, Water Quality Regional Operations Section
Permit. File AWS310287
ECEU Eh
1636 Mail Service Center, Raleigh, North Carolina 27699-1636 FEB 13 2015
Phone: [phone] Internet: http:l/www.ncwater.org g �061
An Equa] Opportunity 1 Affirmative Action Employer — Made in part by recycled paper BY.

Operator.________.'Donnell Komegay
County:== _—______ _--- _____ ________ ________= Duplin
Date:____ _—___---- 07/18/05
Dist.to nearest residence (other than owner): 900 ft.
sows (farrow to finish):=== -------- -------->
sows (farrow to feeder): eder):=__
head (finishing only):===__ ________ _______ - 0
sows (farrow to wean):===__
head (wean to feeder):===__ 2600
Ave. Live Weight for other operations(lbs.)=>
Storage volume for sludge accum. (cu. ft.):=>
Treatment Volume (min. 1 cu. ft./lb.)===____> 1.0
25 Year - 24 Hour Rainfall 7.5
Rainfall in excess of evaporation (in.)===__> 7.0
Drainage area of buildings & lots (sq. ft.)=>
Volume of wash water (gallonslday)====______ >
Temporary storage period (days)_____________> 180
Freeboard(ft.):____________________________> 1.0
Side slopes (inside lagoon):===_____________> 3.0 : 1
Inside top length (ft.}:=___________________> 175.0
Inside top width (ft.):==_-_=_______________> 140.0
Top of dike elevation (ft.):________________> 50.0
Bottom of lagoon elevation {ft.):==_________> 38.0
Seasonal high watertable(SHWT) elev.(ft.):=> 44.0
Total required volume:-===_ ________- 126652 cu. ft.
Actual design volume:====_- ________. 155089 cu. ft.
Stop pumping el.(> or = to 44.0 ft.SHWT)> 45.0 ft.
(> or = to 44.0 ft.Min.)
Required minimum treatment volume: 78000 cu. ft.
Volume at stop pumping elevation: 78281 cu. ft.
Start pumping e1ev.:________________________> 48.3 ft.
Volume at start pumping elevation: 139678 cu. ft.
Actual volume less 25yr=24hr rain: 139777 cu. ft.
NOTE: Verify that temp. storage is adequate:
Req. volume to be pumped:====> 33340 cu. ft.
Actual volume to be pumped:==> 61397 cu, ft.
1�,S Dz5 15P% cd Sv1"1,,,oL1,-1 L � eel TO
Fre e, boa'd V V �r V 1 �n l/ F �`i i" 1
-I
g
1�v

I
Grower: Pleasant Grove'Ursery #2 bb§igned By: JLD
Address: 221 Scott's Store Rd. Checked By. JNT
Mt. Olive, NC 28365 Date: 11/13/96
Countv: DuDlin Sheet 1 of 7
ANAEROBIC WASTE LAGOON
DESIGN
FARM INFORMATION
Farm Population:
Nursery: --------------------.
2600 Hd.
Finishing: - - - - - - - - - - - - - - - -
- - - 0
Farrow toweanling:- - - - - - - - - - - - - - - -
- - - 0
Farrow to feeder: - - - - - - - - - - - - - - - -
- - - 0
Farrow to finish: --------------------
0
Boars: - - - - - - - - - - - - - - - -
- - - 0
Storage Period: ---------------------
180 Days
25Yr. /24 Hr Storm Event --------------------
7.5 In.
"Heavy Rain° Factor Not Applicable
Rainfall in Excess of Evaporation --------------------
7.0 In.
Additional Water Usage: - - - - - - - - - - - - - - - -
- - - 0
Additional Drainage Area --------------------
0
LAGOON INFORMATION
Is Lagoon Designed as an Irregular Shape?
(Y/N) - - - - - - - - - -N
Does Operator Want Emergency Spillway?
(Y/N)-----------N
Is This Design for an Existing Farm?
(Y/N) - - - - - - - - - -Y
Is Drain Tile Req'd to Lower SHWT?
(Y/N)- - - - - - - - - - N
Seasonal High Water Table Elev- - - - - -
- - - - - - -- - - - - - - -
99.80 Ft.
Freeboard: -------------------.
1.0 Ft
Emergency Spillway Flow Depth: Not Applicable
Top of Storm / Spillway Buffer: Not Applicable
Side Slopes: - - - - -
- - - - - - - - - - - - - -
3 :1 (H:V)
Inside Top Length: ------.--------------
120.0 Ft.
Inside Top Width: - - - - -
- - - - - - - - - - - - - -
200.0 Ft
Top of Dike Elevation: --- ---
---------------
103.70 Ft.
Finished Bottom Elevation: - - - - -
- - - - - - - - - - - - - -
93.70 Ft.
Start Pump Elevation: ---------------------
101.90 Ft
Stop Pump Elevation: ---------------------
100.10 Ft
LAGOON VOLUME REQUIRED VOL. DESIGN VOLUMES % REQ'D.
Storm Stor =
15000 (Cu.Ft.)
17,226 (Cu.Ft.)
114.84%
Temporary=
33048 (Cu.Ft)
34,374 (Cu.Ft.)
104.01%
Permanent =
78000 Cu.Ft.
81,594 Cu.Ft.
104.61%
Total Volume =
126.048 (Cu.Ft.)
133.193 (Cu.Ft.)
105.670/9
Min. Required Liner Thickness - - - - - - - - _-----_ 1.5 Ft
Lagoon Surface Area: (Inside TOD) - -- - - - - - - - - - - -- - - - - - 24,000 S.F.
Murphy Family Farms Engineerhg P.O. Box 759, Rose Hill NC 284M
(910) 2a9-2111

YIFAA
NCDENR
North Carolina Department of Environment and
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins
Governor Director
October 27, 2010
Donnell Komegay
Pleasant Grove Nursery
362 Scotts Store Road
Mt. Olive, NC 28365
Natural Resources
Dee Freeman
Secretary
Subject: Sludge Survey Testing Dates
Certificate of Coverage No. AWS310287
Pleasant Grove Nursery
Animal Waste Management System
Duplin County
Dear Donnell Kornegay:
The Division of Water Quality (Division) received your sludge survey information on October
26, 2010. With the survey results, you requested an extension of the sludge survey requirement
for the lagoons at the Pleasant Grove Nursery facility. Due to the amount of treatment volume
available, the Division agrees that a sludge survey is not needed until 2014 for your lagoon
PLG-1. However, a sludge survey will be required for PLG-2 by 2012.
The next sludge survey for the lagoons at Pleasant Grove nursery facility should be performed
before December 31, 2014 for PLG-1 and before December 31, 2012 for PLG-2.
Thank you for your attention to this matter. Please call me at [phone] if you have any
questions.
Sincerely,
J. R. Joshi;�
Animal Feeding Operations Unit
cc: Wilmington Regional Office, Aquifer Protection Section
Duplin County Soil and Water Conservation District
Permit File AWS310287
1636 Mail Service Center, Raleigh, North Carolina 27699-1636
Location: 2728 Capital Blvd., Raleigh, North Carolina 27604
Phone: [phone] l -FAX: [phone] Customer Service: 1-877-623-6748
infemPt- www nrwatamw;Iity nrn
R-ECEIVF-- iD
OCT 282010
BY
Nne
othCdrolina
Naturally
An Foual t7onartunilv', „fir;nzwe Action Emniover

Murphy -Brown, LLC 5/22/20a7 2822 Hwy 24 West
P.O. Box 856
_ Warsaw, NC 28398
( (0 1
NUTRIENT UTILIZATION PLAN
Grower(s): Donnell Kornegay
Farm Name: Pleasant:Grove 1&2
County: Du o lin
Farm Capacity:
Farrow to Wean:
,Farrow to Feeder ,
Farrow to Finish
Wean to Feeder 5200
Feeder.to Finish
Storage Structure: Anaerobic,Lagoon
Storage Period: >180 days^
Application Method - Irrigation
The waste from your animal facility must be land applied:at a speclfled. rate.to prevent'pollution
of surface water and/or groundwater'... The plant nutrients in the anirrilal,waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied. . "
This waste utilization plari uses nitrogen as the limiting nutrient." Waste should be analyzed=.
before each application cycle. AnnUal'soii tests -are strongtyenco`uraged so that all plant "
nutrients can be balanced for realistic yields of the crop to,be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of'thefcrop to be grown and the nutrient
content of the waste. Do not apply more nitrogerkhan the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities; and available water holding capacities.
3. Normally waste shall .be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more.tons per acre annually, but
less than 10 tons per acre.per,year providing that adequate filter strips are established.
4. Do not apply waste on: saturated soils, when it is raining, or wI!-M4ZWJkfF"a $3
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations,. APR 0 3 2009
,5: °Wind conditions should also be considered to avoid drift and ByQwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan Is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which'could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH In the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft , tons, etc.):
Capacky Type "Waste Produced per Animal Total
Farrow to Wean
3212 gaVyr
gavyr
Farrow to Feeder
4015 gallyr
gal/yr
Farrow to Finish
10585 gallyr
gayyr
5200
Wean to Feeder
223 gallyr
1,159,600 gallyr
Feeder to Finish
- 986 gal/yr
a
Total 1,159,600 gallyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs):
Ca aci —Type 'Nitrogen Produced. F±r Animal Total
Farrow to Wean
5.4 lbs/yr
Ibs/yr
Farrow to Feeder
6.5 Ibs/yr
Ibslyr
Farrow to Finish
26 Ibstyr
Ibs/yr
5200
Wean to Feeder
0.48 Ibs/yr
2,496 Ibs/yr
Feeder to Finish
2.3. lbr
Ibstyr
Total 2,496 lbs/yr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total irrigated Acreage: 56.3
Total N Required 1 st Year: 11934.55
Total N Required 2nd Year: 6627.5
Average Annual Nitrogen Requirement of Crops: 9,281.03
Total Nitrogen Produced by Farm: 2,496:00
Nitrogen Balance for Crops: (6,785.03)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2of8

Reception Area Speciftations
u�•
®��7�i7�17®i©�®�I��IS��11'�i
�
�
��
�M
r��
�■■�■
■■r■�
■■i■■
®■��
��
■w■
�■�
_�
®®®mow
®��
®��
�
�
� s�
�r
�w
��
��
rM
®�■
■r�
i■wr■�
®mow
®■�
i■n■
��w����i■■��■��r���w������®��®����®®®sue
�
��
r1N
�■■�■�
�■�
is
�■�
tr_ .�
��
��
��
�r■
�■�
��
��
®®®ems
ate■
��
���■
�
���
wr
.,r
� �
��
■�■
�■■�
�®®■�
®®®®®
r�
��
■s
�
�■
��ai■
w�ri
s
■■■��
��
�■�
®■ram■■
�■�
®®®■_
��■
o■�
s■■s■�r■e�■rrrrr�■irrr■�■���r���■�—��®®®®r•ww®�+■�����■■�
- CO(- n
......._��.�..e�..,.r.�:rY...a++XifArawtti'w4n........+v.:_s.�-w. � ..,..W ^f✓e''i* [ PMa., u:.......y1:..'..e.-

100
100

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
in interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be -grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especiallylate in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less. nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain,earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain Is planted In the fall.
The ideal time to interplant small grain, etc, is late September or early October, Drilling is
recommended over broadcasting. Bermudagrass should be grazed of cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized / unit yield
A
Barley
1.6 lbs N I bushel
B
Hybrid Bermudegrass - Grazed
50 lbs N / ton
C
Hybrid Bermudagrass - Hay
50 lbs N I ton
D
Corn - Grain
1.25 lbs N / bushel
E
Corn - Silage
12 lbs N / ton
F
Cotton
0.12 lbs N I lbs lint
G
Fescue- Grazed
50 lbs N / ton
H
Fescue- Hay
50 lbs N / ton
1
Oats
1.3 Ibs N / bushel
J
Rye
2.4 lbs N / bushel
K
Small Grain - Grazed
50 lbs N / acre
L
Small Grain - Hay
50 lbs N / acre
M
Grain Sorghum
2.5 lbs N I cwt
N
Wheat
2.4 lbs N / bushel
O
Soybean
4.0 lbs N / bushel
P
Pine Trees
40 lbs N / acre I yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4 of 8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PAN/animal Farm TotaV r
Farrow to Wean 0.84
Farrow to Feeder 1
Farrow to Finish 4.1
5200 Wean to Feeder 0.072 374.4
Feeder to Finish 0.36
The waste utilization plan must contain provisions for periodic land,application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 374.4 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you Wit have approximately 1872 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 6 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 14.976 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time'of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
`This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated property to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Cali your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 8

Application Rate Guide"
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract
Hydrant
Type
Crop
in/hr.
* inches
T3226
1
AuB
D
0.6
1
T3226
2
AuB
D
0.6
1
T3226
3
AuB
D
0.6
1
T3226
4
AuB
D
0.6
1
T3226
5
AuB
D
0.6
1
T3226
6
AuB
D
0.6
1
T3226
7
AuB
D
0.6
1
T3226
a
AuB
D
0.6
1
T3226
9
AuB
D
0.6
1
T3226
10
AuB
D
0.6
1
T3226
11
AuB
D
0.6
1
subl-9
AuB
D
0.6
1
sub10-11
AuB
D
0.6
1
sub12
AuB
C
0.6
1
6 of 8

Additional Comments:
Sub acres are acres picked up_using a honey wagon. This is optional in this
fan. Sub 12 is the extension of pulls 10 and 1.1, groWer wiii be using the
hone onto aP21Y to this section of the field. This -is also optional.
Grower has the option of plandng tobacco on pulls 1,2,3,10 and 11 at the
rate of 91 Ibs. N per acre, during: the windows of March 15 - June.
7of8

NUTRIENT- UTILIZATION PLAN, CERTIFICATION
Name of Farm: Pleasant Grove 1&2
Owner: Donnell Kornegay
Manager:
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: /—� Donnell
Signature:
Name of Manager (if different from owner):
S �l A 7
Signature:
Date
Name of Technical Specialist: _ Toni W._King _
Affiliation: Murphy -Brown, LLC:
Address: _2822°Hwy 24 West, PO Drawer 856
Warsaw, NC 28398
Telephone: _ A910j 293-3434
Signature:
Date
8of8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns.or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing himther the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recieving crop tvpe, or available land.
Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulationsthat restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1of3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
{continued}
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste -shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Wastelnutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2of3

�0P
� W
O G
6
j r
4 lqii� -.<.
Kornegay Brothers Inc.
Pleasant Grove Nursery 1 &2
221 Scotts Store Road
Mt. Olive NC 28365
Dear Kornegay Brothers Inc.:
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P_ E., Director
Division of Water Quality
May 1, 2003
Subject: Certificate of Coverage No. AWS310287
Pleasant Grove Nursery 1 &2
Swine Waste Collection, Treatment,
Storage and Application System
Duplin County
On April 28, 2003, the North Carolina General Assembly ratified Senate Bill 733 which directs the
Division of Water Quality (Division) to extend the expiration date of the Swine Waste Operation General
Permit AWG100000. Therefore, the General Permit has been re -issued by the Division to extend the
expiration date to October 1, 2004. During the period of this extension the Division will be working with
all interested parties on the development of a new version of the Non -Discharge General Permit.
In accordance with your application received on January 30, 2003 and in accordance with the directive of
Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to Komegay
Brothers Inc., authorizing the operation of the subject animal waste collection, treatment, storage and land
application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AWS310287 which expired on April 30, 2003.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Pleasant Grove Nursery 1&2, located in Duplin County, with an animal capacity
of no greater than an annual average of 5200 Wean to Feeder swine and the application to land as
specified in the facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to
Wean or Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are
unneccessary, they may be replaced by an equivalent number of sows. Any of the sows may be replaced
by gilts at a rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until October 1, 2004. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property. WX
ENOR
Non -Discharge Permitting Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
Customer Service Center
An Equal Opportunity Action Employer
Internet httplm2o.enr.state.nc.ur./ndpu
Telephone [phone] Fax [phone]
Telephone [phone]
50% recycled/10% post -consumer paper

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, -and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume).of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within fi0 days ofutilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3 of 3

Upon abandonment or depopulation for a period of four years or more, the Permittee trust submit
documentation to the Division demonstrating that all c=irrent l%?PCS standards aie inet prior io restocking
0
Uu
of the facility.
Per NRCS standards a 100 foot separation shall be maintained between water supply wells and any
lagoon or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Wilmington Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Sue Homewood at [phone] ext. 502.
Sincerely,
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
Wilmington Regional Office, Water Quality Section
Duplin County Health Department
Duplin County Soil and Water Conservation District
Permit File AWS310287
NDPU Files

v.,.o::,n :;.ti :: {t?.:id:[.v :•er;c. v+:rc:{?,':+ CxzJ; �' ;;vv.:;;+. •;.�;,;:.,:::x:.izi; 1:2-;� ,..a'ti:: z<z:^
;`$... , � ,. h:�r.n .,.dti':i::.• :,.•rq, n;:;�..c .`•�. ':2:' ':§� .'¢sc:sv ��{{:,t;t3;>:
W,vt.:� ,.}. �•..$'..v A:uQv. .K ::iw w3 ':J:.: "::<.';:::ix:i?ir!.: ,S .i�:
iZ:.i::?S`.' v. 4rai'. %•.{.. .5;:. '.W7r..Sv:� .��rS:. J ���:�:..'�`:•?l::'Y::t.S:::.'>::i'i: ;:v:..:
:.c:{..y:!.!! }�}..\.:C.;,;/: r::: Y.::n.:CC.1..v.......:L:. - ..::'.!!:{:: •:{ :.:v:.::.::::. }-...:
PRODUCER: Pleasant Grove Nurseries 1 & 2
LOCATION:
TELEPHONE:
TYPE OPERATION:
NUMBER OF ANIMALS:
(Design Capacity)
221 Scotts Store Road
Mt. Olive, NC 28365
Wean - Feeder
5200
IA /-4 r_IT,4 till-.l,l VtV
JA N 3 0 2003
I
NON-DI,S0.H. 909E PERMITTING
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface and/or groundwater. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied. This waste utilization plan uses nitrogen as the limiting nutrient. Waste
should be analyzed before each application cycle. Annual soil tests are strongly encouraged
so that all plant nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
i the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange,
capacities, and available water holding capacities, Normally waste shall not be applied to land
eroding at greater than 5 tons per acre per year. With special precautions, waste may be
applied to land eroding at up to 10 tons per year. Do not apply waste on saturated soils, when
it is raining, or when the surface is frozen. Either of these conditions may result in runoff to
surface waters which is not allowed under DEM regulations. Wind conditions should also be
considered to avoid drift and downwind odor problems. To maximize the value of nutrients for
crop production and to reduce the potential for pollution, the waste should be applied to a
growing crop or applied to bare ground not more than 30 days prior to planting. Injecting the
waste or disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for analysis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A
NCAC 2H.0217 adopted by the Environmental Management Commission.
Page 1

See attached map showing the fields to be used for the utilization of waste water.
Application of Waste by Irrigation
Field Soil Type Crop Application Application
No. Rate (In/Hr) Amount (in.)
THIS TABLE IS NOT NEEDED IF WASTE IS NOT BEING APPLIED BY IRRIGATION, HOWEVER A SIMILAR TABLE WILL
BE NEEDED FOR DRY LITTER OR SLURRY.
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 MONTHS. In no instance should the volume of
waste being stored in your structure exceed Elevation *see lagoon design.
Call the local Natural Resources Conservation Service (formerly Soil Conservation Service) or Soil
and Water Conservation District office after you receive the waste analysis report for assistance in
determining the amount per acre to apply and the proper application rate prior to applying the
waste.
Narrative of operation:' This is a 2 year plan and the acres used are "effective irrigated" acres.
This plan has more acres than are need for waste utilization. The grower may irrigate on the
on the corn / wheat / soybeans as indicated on page 2, but only needs _20_acres to utilize the _
nitrogen produced. He may have tobacco, sweet potatoes, etc. in any of the remaining acres,
but these crops will not be used for waste utilization.
Page 4

5,200 animals X 0,42 (tons) waste/animal/year = 2,184 (tons) waste/year.
Amount of Plant Available Nitrogen (PAN) Produced Per Year
5,200 animals X Q," lbs. PAN/animal/year 2,496 lbs. PAN/year. (PAN from N.C.
Guide Std. 633) 2 Years Tech
4,992
Applying the above amount- of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner
The following acreage will be needed for waste application based on the crop to be grown and
surface application:
Table 1: ACRES OWNED BY PRODUCER
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
# No. Type Per Acre Utilized Application
T_ 3226
1
AuB
Corn
85
13.77
1170,45
March - June
t3226
2
AuB
Corn
85
15.32
1302.2
March - June
T3226
3
AuB
Corn
85
5.97
507.45
March - June
T3226
4
AuB
Corn
85
9.18
780.3
March - June
T3226
1
AuS
Wheat
96
13.77
1321.92
Oct - March
T3226
2
AuB
Wheat
96
15.32
1470.72
Oct - March
T3226
3
AuB
Wheat
96
5.97
573.12
Oct - March
T3226
4
AuB
Wheat
96
9.18
881.28
Oct.- March
T3226
1
AuB
Soybeans (DC)
90
13.77
1239.3
June- Sept
T3226
2
AuB
Soybeans (DC)
90
15.32
1378.8
June - Sept
T3226
3
AuB
Soybeans (DC)
90
5.97
537.3
June - Sept
T3226
4
AuB
Soybeans (DC)
90
9.18
826.2
June - Sept
Total
44.24
10, 625.54
*This N is from animal waste only. If nutrients from other sources such as commercial fertilizer are
applied, they must be accounted for. N mu t be based on rea stic yield expectation.
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N
requirements. Beginning in 1996 the Coastal Zone Management Act will require farmers in some
eastern counties of North Caroline to have a nutrient management plan that addresses all nutrients.
This plan only addresses Nitrogen.
Page 2

has 1s P`f�' S''. a+�,•r ��1 fed �+l ''��; Is�;��r.+' 3L't'�•' - �:r_,tt.��;.�;:a. Fi'_ _ � s'• ?h 4
rs;� t" �Z ��i �e'``� � i 4f���� l�,r v����''.r�, `7�_'jS'};1 a 7 ;� �y-r a � i� m ,p.:,iq�• �7�,�`+r �k`
Table
(Agreement with adjacent landowner must be attached)
(Required only operator does not own adequate land [see
Required Specification
Tract _ Field Soil Crop Lbs. N Acres Lbs. N Month of
# No. Type Per Acre* Utilized Application
* See footnote for Table 1.
Total -
Totals from above Tables
Acres Lbs. N
Utilized
Table 1 !44.24
24 10,626
Table 2 00 -Total 10-,6-26 * 2 Years
Amount of N Produced 4,992 * 2 Years
Surplus or Deficit (5,634)
NOTE. The Waste Utilization Plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to prevent over
application of nutrient or other elements.
Page 3

I
S.:{;::^5 ;.:::: ii:i'h�itir,::t'{t:.� .;'•1 .:{ii.: t: v::i�;{' :_ \- '- ::2•:i::r[.:.i:tii.}:.ni.:iS.:-- .::{2.. :.
l..�r
iu}iy�
::t:• .\.� :>. -.Y" tiiJ.r i1N:~Ci+:�:ii::}.::R`;n`%'•'. }{`:=:ii:<:};
Ix,
:.}}i ♦vit:..ty � :'=:i+`:::t.'Vie:ti'��:i�ti��iv�uii�{i��vi':�`n':yi�:i�ii:{:_i�•'-
.y.:.•,...1.. ,..L ..G',•.c-:....w:.,:t. :,:.: .a':.;;.:: t �t. r+:\'.;ii.{}�S."•.'.:%>::i:::i>.2ii.:•.:::::i<..:t:�'S:�{:.
} 454::�:. .� ?v'-.�.:**fir+. #VI.,.}.w . .. }.: :tii::.�:i :..�rv.�::.. � .:: }:.1{h:n: :::::?: i'.`-•: .:::::.
See attached map showing the fields to be used for the utilization of waste water.
Application of Waste by Irrigation
Field Soil Type Crop Application Application
No. Rate (In/Hr) Amount (in.)
1,2,3,4 AuB Row Crops 0.5 .5-1.0
THIS TABLE 1S NOT NEEDED IF WASTE IS NOT BEING APPLIED BY IRRIGATION, HOWEVER A SIMILAR TABLE WILL
BE NEEDED FOR DRY LITTER OR SLURRY.
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 MONTHS. In no instance should the volume of
waste being stored in your structure exceed Elevation *see lagoon design.
Call the local Natural Resources Conservation Service (formerly Soil Conservation Service) or Soil
and Water Conservation District office after you receive the waste analysis report for assistance in
determining the amount per acre to apply and the proper application rate prior to applying the
waste.
Narrative of operation:
Page 4

`��'-�''i =.��F�:',a�."�f�'r'eY�t:;,�;',{�'�=''��Y,1`!r77•'4. n �l rf_�y^{s 4:�': r,�':j,�y(r ��4... :��`'.',, ,M _ i �''��� •-f ,
+�� ,,�i4�.r�•�'� f}'NJl� � hr���}h���`�� -�i:• ij,v ��� 6 '.1 � ���W s;l �45 +��`i � � �'d � y-��r f -E' +:i�i'��� �•�'� � � r �;, '{ �
�. ': �1'.'�• r�; �: r . ] a7,f� . ;� Si . ..-f.sY^ n.+'fan +sr. - 1. ,fi' r f:- ��'• a �•A.:crr`!� ��;
REQUIRED SPECIFICATIONS
1 Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of waste, he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner of the facility to
secure an update of the Waste Utilization Plan when there is a change in the operation,
increase in the number of animals, method of utilization, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climatic conditions, and level
-of management, unless there are regulations that restrict the rate of application for other
nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but less than 10 tons per acre per
year providing grass filter strips are installed where runoff leaves the field. (See FOTG
Standard 393 - Filter Strip).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6 When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland,
the waste may be broadcast provided the application does not occur during a season
prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor or flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
Page 5

REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a
high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste
shall not be applied more than 30 days prior to planting of the crop or forages breaking
dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and from any perennial stream or river (other than an irrigation ditch or canal. Animal
waste other than swine waste from facilities sited on or after October 1, 1995), shall not be
i applied closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips).
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 - Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site by a "technical specialist'.
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
Page 6

REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced as necessary to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied pre -plant with no further applications animal waste
during the crop season.
21 Highly visible_ markers shall be installed to mark the top and bottom elevations of the
-temporary storage (pumping volume) of all .waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the.soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste analysis records shall be kept
for five years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for ail other waste shall be maintained for five (5) years.
23
Dead animals will be disposed of in a manner that meets North Carolina regulations.
Page 7

a
Name of Farm:
Owner / Manager Agreement
0, ZZ
(we) understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. i (we) know that any expansion -to the existing design capacity of the
waste treatment and storage system or construction of new facilities will require a new
certification to be submitted to the Division of Environment Management (DEM) before the
new animals are stocked. I (we) also understand that there must be no discharge of
animal waste from this system to surface waters of the state from a storm event less
severe than the 25-year, 24-hour storm. The approved plan will be filed on -site at the farm
office and at the office of the local Soil and Water Conservation District and will be
available for review by DEM upon request.
Name of Facility Owner: Ar', ors J OL �c�jtnt, �� E Kor►��+` ��
(Please print)
A K 0 rV\ e Sa.)
Signature: Date: !J
Name of Manager (if different from own }:
Signature: ( Date: Z
1- 2G-Q 3_
Name of Technical Specialist: (Please print) - Toni W. King
Affiliation: Murphy - Brown
Address (Agency): P.O. Box 856
Warsaw, NC 28398
Signature: Date
Page 8

Sheetl
IRRIGATION SYSTEM DESIGN PARAMETERS
Landowner/Operator Name: Pleasant Grove Nurseries 1&2
Address: 221 Scotts Store Rd.
Mt. Olive, NC 28365
Telephone: [phone]
Table 1 - Field Specifications
Approximate
Maximum
Useable Size
Field of Field
Number (acres)
Soil TVDe Sloge % Cror)(s)
County: Duplin
Date: 02/18/2002
Maximum
Maximum
Application
Application
per Irrigation .
Rate
Cycle
(lnlhr)
(inches) Comments
1
13.77
AuB
0-2
Corn, Wheat, Soybeans
0.5
0.5
Has more land under
2
15.32
AuB
0-2,
Corn, Wheat, Soybeans
0.5
0.5
irrigation than needed for
3
5.97
AuB
0-2
Corn, Wheat, Soybeans
0.5
0.5
receiving effluent -- may
4
9.18
AuB
0-2
Corn, Wheat, Soybeans
0.5
0.5
rotate tobacco on a portion
of this field. Will not apply
effluent to tobacco.
44.24

Sheet2
TABLE 2 - Travelling Irrigation Gun Settings
Make, Model and Type of Equipment:
Field No. Travel Application TRAVEL LANE Wetted Nozzle Operating Operating
and Speed Rate Effective Effective Diameter Diameter Pressure Pressure Arc
Hvdrant No. (ft/min) hnlhr.) Widthfft_) Lenoth(ftl (feet) finches) at C�'unfnsil at rPellnsil Pattern f nmmPnts - Arm-, nar nidi
F1 H 1
3.89
0.39
200
1000
305
.9 T-bore
60
90
270
4.59
FiH2
3.89
0.39
200
1000
305
.9 T-bore
60
90
270
4.59
F1 H3
3.89
0.39
200
1000
305
.9 T-bore
60
90
270
4.59
F2H4
3.89
0.39
200
1000
305
.9 T-bare
60
90
270
4.59
F2H5
3.89 1
0.39
200
1000
305
.9 T-bore
60
90
270 1
4.59
F2H6
3.89
0.39
200
1000
305
.9 T-bore
60
90
270
4.59
F2H7
3.89
0.39
150
450
305
.9 T-bore
60
90
200
1.55
F3H8
.3.89
0.39
200
680
305
.9 T-bore
60
90
270
3.12
F3H9
3.89
0.39
200
620
305
.9 T-bore
60
90
270
2.85
F4H10
3.89
0.39
200
1000
305
.9 T-bare
60
90•
270
4.59
F4H11
3.89
0.39
200
1000
305
.9T-bare
60
90
270
4.59
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
0.00
44.249

TABLE 4 - Irrigation System Speciiicutions
Traveling
Irrigation Gud
Solid Set
Irrigation
Flow Rate of Sprinkler (gpm)
$�
Aerating Pressure at Pump (psi)
Design Precipitation Rate (in/hr)
-"�
Hose Length (feet)
�/
XXXXXXXX.
Type of Speed Compensation
�h�
xxxxx xx
Pump Type (PTO, Engine, Electric)
Pump Power Requirement (lip)
I
TABLE 5 - Thrust Block Specifications
t)nelnnnr r nv nrnvLln thruct hinelt ttntnilt nn connratn ehnrot.
LOCATION
THRUST BLOCK
AREA (sq. ft.
900 Mild
Dead End
3,�3
Tee
r],
'See USDA -MRCS Field Ofi'ice Technical Guide, Section IV, Practice Code 430-DD.
r i
MRCS, NC
J r,M, 1996

EXHIBrf D-5
IRRIGATION SYSTEM DESIGNER
Name: {,, r C...-
Company:
Address: P,O, rS,,, _ a _ 4:s4-_. j-9
Phone: 110 .18q - 6y 3q
U� QUIRI✓D DOCUMENTATION
-The following details of design and materials must accompany all irrigation designs:
I. A scale drawing of the proposed irrigation sysiein which includes hydrant locations, travel lanes, pipeline routes, thrust block locations and buffer areas where applicable.
2. Assumptions and computations for determining total dynamic licad and horsepower requirements.
3. Computations used to determine all mainline and lateral pipe sizes,
4. Sources and/or calculations used for determining application rates,
S. Computations used to determine the size of thrust blocks and illustrations of all thrust block configurations required in die system.
6. Manufacturer's specifications for the irrigation pump, traveler and sprinkler(s).
7. Manufacturer's specifications for toe irrigation pipe and/or USDA -MRCS standard for Irrlgatfon Water Conveyance,
N.C. Field Ofrice Techuiical Guide, Section 1V, Practice'Code430•DD.
8. The information required by this form are the minimum requirements. It is the responsibility of the designer to consider all relevant factors at a particular site and address them as
appropriate.
9. Irrigation pipes should not be installed in lagoon or storage pond embaivanents without the approval of the designer.
NOTE: A buffer strip _ feet wide or wider must be maintained between the limits of (lie irrigation system and all perennial ,
streams and surface waters per NC Statutes.
4
MRCS, NC
NNE, 1996

EXJMTT D-6
Narrative of Irrigation System Operation
Describe the operation of the system in the space provided below or on a similar sheet most convinient to the d6signer/supplier
Include procedures such as start-up, shut -down, %vi nteriz&(ion and regular maintenance of all equipment.
Ck drr - A
ele—s, ' A. 41
U
e., IS -f tek (-^—. re --e'-Ve e. f /0 4K+ r, ---PA-q SAC f�ti
C"41'0^ 4"
i --� 4 eA ed d%A )4;, r- 4 e. te Ile I e—
V'- r 4:-1
trcA�— Ce. -5 r
riv^!'e.. At :e
711-0— ri y. M, nc f L'11 Arl
�"J
. rEl r—/.
4
I
4), rl A
j,
ek :�Pz�-e.d
4v P—,K e. 4-cJ
e4r
—"f'
11( n- 4r-
0, A-4-
"r�:— Ac—
rA
1:41
X
1,4- �e—•4
e r,
14 /1
MRCS, NC
JUKE, 1996

.gyp
�
i 'I
Lk

r rr �' �,�nr r,..JP,rY.•^' �� ,� r S� s P'w �� 4{^ r a. t + 's"t - ° ,
Y`f5 ! S it f Ji 1 i M �4
� ��y
�VO
7; t}arc
r ! [ F'k'r r �' i r wr''',S tr 5i9J,'rr 4 Lr
+fir {.R� ! r
u r{t�fl tl ri f�� H P end I�i
d�Sri,
��1�.-Ny*`"�'r3,rr9�`
�'a�"r?�it,
�!"!��r�l{ It y Ig(�Ja
t ; �� x{M
y'w V
,+ r`Zr Vh?rt�'r �,��G .d` �'Y % & *x l3,r n r•ti'Fi,
,� " � I - a l�It'ff`• 'r r Iv �'.ty.,2 •,�i �ii�r
' � ��, ark � '$ ,r�a4i y;�� tlj�t+�•'
YI r"d1 r l `� fr rt +r��hlkd"sw°„s+`td „�Y Jv
h�r{
.+
SY�rN
I t t h {
*A�.
��
I , i ' J �tf � � .0 �� �� ��yt L�� �j^�f • ` Ir' t � r ��' Vr �+ - � - ' { v
u II t
"9 k �{ w irl r '✓idrv�' a . 'h�
�;
` rr r { Rt 1 ;.%I JII _� �v ,{ r,lld ir✓�t5�i�?, ��� 7 I
vr��t �af�`{�"'i �v<, �°��ar�� ir'�{�r^a��+"F`��+i���,�r•u�ll tYi ri ary�y j��g,
-
t
ir��ya.r,f
e E, I }tty v ,rr h I
@@ 'm?"
nF:4,�
TIT
;hf I t e9 V { �.4i �,��,'• ` �^ ��x ��.I �'� ��w j {a'th.� ��� ("!, n+A } �� ?pg � ;� +W
IN C Vic'
��yryC,tr'C;y!,r�`r�t !r�
r.. i
j tt r,1
b'ti '~?! Y .+}g 1
`�ti'lwte"r�"�fm•`{ I ��i.�y� :r((rII� i��4.�rf����'�7$�''S'i;�]}4#a yy�� � y,�r �J
c�'��
h!P 4 'x'.,i.ri?vf k .0W+•W..' •✓itr+Y P� t�
�kYp Y,in � ����? � w"�+ �h ,C�' 4 ;. ��Sd ptf r�• ° � e4�7 f"n� ;��r � I;
r` rF7
r
•N���J,p7 1 I 't. �`S' t�
ifrX �t(1 AIR
r"im j� !21FvT I Ck4f
r It aL1r ry
V, "� ,
�jrRrIyYV3+�y �fN„ �Ye'4t.¢,r.,'•,���ik` `��''fir�.r tia�+h'i�, '4�,j�1pFi!r�a� r �- s
fir1 u
.���� Y.rJt •{ �' `yt r r,, �5,�'N yy t v
e,qr > k�i'
4Fi J �I� #�� �{ { f �? ti ;{s ���. +,C '�I.�-C C.Kr'd.�,6 'tr y� ',r�' ,4f' /+ '+ • v' '
71WHO�4' r����'. Id1�i ,{,r•'�f S r 4S i Y ""fti a,r# 4 ti l�t�+�r � I �tYd3` °YM'?r r
; d{ k +% r J Y' t q ; e Wa rry ry �I ye
0, �IQ 1'� f •' R 5 - Ar � µ'! ' 1 6 1 i + ;+I 'i/ �l .. � f , f � aYk
'rti� Inr: {bt ti { I - ++i r I w e r7+ r iy'•1En �{y r`' �` f,G Gay
� ` � �'�y ' %' a � `� °� r s f I?,' c � c Aw ] a ,�y.��@y i .,,i p^•
,� y 4 a!"r�T y r �+� �� �f, ,�r�� • � r 't '� I r,;i�� � �+ �, �` �4 ° ....E r r.r � � �'w
'� 3+ ,.�1 d `{ � Ra '�' f� � v r']"',4N i a M•"1"` �•_.t �," t {i + t![1 + ,�d
wi kA7� � ^� 'yd{F .S "`� � ,L S5 rtwrr�•k"}*�y"
1 y" 3 y,r 1 nr7 l I G#
ih
r
.v,ds. � a r• 3'r� �� Ar r ] 1 } � � d ,I� 1 $
,.� S' f ,� io ,,..,,}}� r .�.? i i F �'� + ,c•i� �K .v11 }�t T , �
y1'a iP uy{y Ai C� ! r rr'F �'! "' �`f �tYy /'��w I :
dl.r''I_'i,�,4 a� �
ear
/1W,
d •rx
I
Al.-tt
tFPy?yfi�LlYI,.r w�v:Ati
, �'�1"k� 3 •i "1'r � M wA' Ali
k,,++ r ,�� i 5�,� y frL'y., ,i' rb�rN try ,T^.� ... ?�+ibr^. �� (iV Y Y ��;_} 1Y Rya ✓;�'13
r,r� SSr � 1 Jf � 117'd i+. p y J 7P' � rr R ti� ry�'"1j. A'K fir. �$ Yi '!' x,YlY •�F7`% r
'Y^'CY�k a" y.. j? �A 4� � I�# �F p, 41ro. +' � flh�i} �iYr�? f �.��1 q If N ;y'+S�i w�l]:Iq'! .Ili'�.I�M�C4 y'4'4` A N�,r L7'•' "}F'1�1 Vl�.
"'`�. bra i �' hi (i'S7 a� ��� 'h,� i,�i,,„,�`d`� ` at ••jI w4+; :frrl t I, � ,.lj"f.4^fe'��}� ai4Yj �` z��tl,'�+�
��4. �I '.,'�t1• E _'s:�sy �!n� :`�'�a,e if,"b�X3��a�:�eW�i�t.!"�e.�`�k��t`'��`'����'�F,,�"; �sl�,k�'�;H-r?°,�r°,a
I

rr
n
r
r
f
;r� QV�£ :CLIT'F�L'1�� /I�r � L• /�/� � Off:Ji

Z
z
0
v

Y,,, '•t. :I; � 4.'4r ' r, Y � +•: }, i t R S
11� i t '-�r ' 1( r } r � r+' 'T' k J ,� Rn 1 _ ' r'rY , + k' �rA. � .y �"Y �,••x- '.I�ii `_ s •_ -
49,
"To
•Y• '[ ,+ .'. ,ii � Y �a �+{ 7 t'J S%.; v 1,..r,.,F;'.,1. [ i•' 7_!e,
kyl t4r �' r S t,:: [ ,.,.rr� "L�i :ij: y}/,' S,,+ �,r N1e,,V'r `_a• I'14 . i rl � � r J ` +Sj ,r �'r
!r:y •F e'• :, � fi rr{r �y i; Js. .(t►�` � _ 1t }r'ry'rJ { V'tJ,.,;.�* ti r ,'�.
{`r Na��' � ri ��;. + .�#l^;7•;,Tt?'�.. 'I•li t ri3.•r �,. f J.•, r -, fi•sr _\}f sr yr +, .�.•',�,�, .
`:� ,+ .,r`' , it `•["t''� tl �} r. ..; �. \ .tr f J� , +�'�' p,, '�r!p 41 , �I- t./ -."�'. �R. b
1' �' y 7'w } t1��i' :a� ( .1'�f (i` ice•' a }� i�i t'�fy =-i'rf r�'C' Fr., !r`'•�• `i '•��� •,.a' 7sv
'+,ri t% ~�♦, 1 ; Rs. i, `` P+• i•I �, ti � , ii„ � � .! _ F s_+15��;J t�1"r_.TM�-� t}:,f r ,^�.. s� .l!,' • • � �i ]'rr •�
N'::• 'r -�i i'. ,ty rp ,, .!};1, >yr-F- 'r•! `f :l'r" v.iy++"1',``'�ce .4f""'r,T-. ;'' ':rS,,
1, E' r.:r.lS�r}1 a/y: 1. ,a J ,� J.'.� , •js, r�, rP,rnq ,N ql ;\a S�'}'� i..;S.q • '. ;�,• �, ����(yyy "4 'l
'✓� r>" ar'' E 74 .r'" '�L;��a �Y � �i [ R ^s x ',Cu..r s S'�j t,: �' :i,':iY;�
f `IDS' l�t '• C S.J t ♦ a r ' � �' •1iT '�► ��' 'j if '1 •i
�� :�. +, �'' rVr� ';\�- "' 'i_.: "P IS °,�[ 1 n� y � -,S t,y �i l�.�., fJ., ti�h �[.-1'.�Sr'u� ,r :'a►�CgT.�"If`n �' '_�.
r'• lr J ' 1 ! t��/ �' l j, i 'h R 5 �.� 1 w{S w S �,•r• .,
_ti°.] r [: :. f s'� - '-.�• t`'I: ^rti: 04P,
Qra t�r'� �af r li4i-lt"� ,,. [, !t! .l' [ ! '(alr :4 /.: ': "1...! �• ":"a\
ti .1 ,�yt . a �'��'• {: ' to •L'4'' i:y r? �r [9Y'+S�'.... '.e,/�['•;a'; rr, S - ' 1.I - 16) -"1;. �' �r ': 1 1 ,.r:' r' ; �1 rt '. r ``
;.t �a ';"' �fi'; .:ti •� :'�.ly. A4r� 'v +',^4,� 1� rll Jt'• p �.� 4 ash ! F+ W! v �r. r•.4i \ -., ',, :�\` S ','p
�� �t'
Jf 5r }
�,J.s �at''' ���,.�.., `1y.;:: ��•_ �-.. � :j�f, ryr 1�,,rr.,r art �.� � 4 � •r�'' :��r '.�r..l ` 'T' +� .1. ,�i': �r.;
� �, �. ,,• � y' N`'�.7� � T�`}I r ti�"'f; ., s [i I r 1 i r s , i%6'xii\ i ' , . � '
1'� i� 's ~�": •�Yr r ? [ I� � ly('.. � �}'+L� i r,.rri 1! .yf_}M1. e, .'ri`. may.'. \i .r,
V(i`L,•{ 't! . ,! W.y, i'. .r * tl• ,''�,. :,�i .i'�,, +� �4�41rn u..�'►' S'� J {"{ ,,{{'� . ; '�,�. .
i_r� t i E,. �L, rr"•9i i�: sr?ti. :�'Y SJ, • �;1 1 •R y'14e; ,+' . t[,•3
a')+- } "S � � �.,-i r s7 t'j 1, ^.F'.ti:q:S[. .:;�,' .Qr. �;• � �'N�y_ •j'.0 _%� ; ,i -J �4,^"''7' .
ter'• �r" :'�, r.:Y" ..r,. i t tp^�',' [ i . •-
Wy
pY�.� ��•:
[�? ♦ •.0. 7 ;y 1:r1 "i �`- s.- q{ ly MOW-
OFr +'
•�W�':�. ,y'�r5t_. ,.1.: -1- efM y. .,.C,,, �y('.'r.a �j- r/'QK.('!: • ' P. :.,.z..
.pj, rS�':rj }' r� J^'•li�.- :i'� Y � '�. . 'k,. 'r� Y.y •f-pS• f
wit':yy:•3,L,. ^'ti' Y .f!/
�!+�+� '[ .'l� 1 i J 1 , i I•'•�4 1.;: ;'-
t,tp•� � 1 S rk,;`n;'Se *', { ;: -,i r + -Y ,�,7 c P� �••�`1 r�!.t t 1. ': rs� 's = �`'�'N� .a• '+•-s:.,r;
r
glx..r'�6; i 1 .+r . + ai.l i:�ae•' 1' r �=!•
? • ,�'i�t�. 'ls,,c+a1 sY N; - J r.a t fir, F. �< 'S_ r ,l'r. i;;.f r is -i ��.h� J 'If an.F r+ P C ?i Ltipa "! r>pr n s
'. �1�?:I[,. I : I Nr r i - 1: .�
• � , � �,� S J r :,i r ,� �,G'�' +/
,� t,y�/q{. -t �• ,��
1 I_ �` �`.' "' > 1' ::j J't'- Mr'"•H ',i !' ''.5 P' ''� i,-/' { ,4 h C: t' by , !i'. 1� •',,' 'Jil,fnµ' i, �.
mm
.¢. �.�. 'F3„ �IJI� ��� J'F , ��!iyy" �6' f n[:• r r 'r,$C1'v � r�.: �k- 1�'1f'r<} 1 ✓1-, t{�'r; "t',' -riTr "V7, 'r•�''�`,r� 1� �4 -Y':
4 J'•+ �tr�_ } r rr ?5F a .st d� -'+ s !t. l „I ` yf , '�« :1,' .r•
+Y-`j^ F? �-`.YG7 �-•ts'a! � t � 'Jr :'.•�br .i 7 Y ,.s t-r-,r s ' 1 S 1 : } ' ,ay - J '1 i.S •Y ,,h .i.. _ i ; 'i _ -' 1r .I. 15 .+ t7 .:�-a i~.�:. . '�. 7-r v��J�S;", `.'
ii• l '•' l' : J � �'`•� W a!�ry' rr .1 .i1 ,', �Y L
�,4: ''4 � '.+'J �• ''�,1� fi.'; �.I �r �. i. '�Er,Y': :�'rS�,�, _ �' I r !l[+y :I t '�• -} ti =S ' \���-� _ a
a _yr3/i=..fir,. r..th'#IR /rp/r:�Y,;� 1!. 'y �,„ �iJ �. �# .��f=Y;�1'? l .r, •, sl't �'':'•"+-r � .r 1 1-` a!}�'L,� N..: � � \ir a'�S .�'s;' .�:'�"'Ji
�_ •."lf, :tin is .!'.�'C; .�'-., ,F ,st ,. Z, x:, J �e:.`��. :J.t�. r. Y `� G��'+ �_� � . . b �1 �: .:r l,'-��: IIrT - .�i
�� ^ty� i J -'11q 's'ft :. v'ri �nr1.` ['i •'i1L /'• t+;� �• �1:.: 1: e `-5 `+�' .r F],xai',•
a•�`"�`- : ,,,,1 , � r,y..,. , ,: as. '# -:' .'f" "•..*SS.�.�1i'. . r �`:�r:: ' �. � e' r1, � a . -•+; . �'. �,:
f;.*��•�.,. ��? 4';� �+� lyl ' { J'17i ���,'(i. ���el I �• t .l r+L ?e�,y - h !'f'r+"u !jiP',��'y �r +{ i J.. '1 .� .^�, �
i„1n cart :�f [ I;f'1 j Y [`, E= ,fir; r, �;;.;," )v,f�.. 'J� I ••.�,�"'"''_i fl f. rk �+'� �{i }. ', y 1 ')! f ! J(� 1,,,, y,•:i,. yy�..
rt YDt• 4 y 7d 61 k :i. r' fJ t. ,y,r ,,Y, �,i l+S :r�•,i - '� 4:: � i a '\ • 'sl ..� . •7.
i W+ �"� <!:f k h1 tt•J°,. r 3 �+� a♦_', '•�wr,.�i r" a :1 'r7 "r �f x s..!�'i1 fir: n !ft ti r, !7' '(`7 0` uu r1 %: 1s f.r I 4
," •'t_:'1 1�• +,+6t+�#�•f%�"b$.rL•S'�r!" J Y'b `.1 •'�'`, �' r14'�. �a1;;,L E•'�[ +. Y'•f''✓+a r• 'T'. 'r
,1{1 ., r,. .y�®,' r .r-' � ••+is / �,yf ':{ .+.Aa� ^'.C� r��r .a r..,,,�t.
�j �.s,� `P �' :t 1 4Id � 'rw• irk 11 i 7 ',}+: �r ..t '^� ! 1 f .i r •'-,41 �t' �[, •'s' � � '. fr . t �.r., �..
Lp :� "'#'`.�1, ,! �°ry'W....l� r•. !, -t ku3,
• 4ie. 1F, h' - ti~I r o •i�. .t I +{�//"yr lY ''r `r;l K e. ^`U"�,". s� ,..•rr�_• „ •t, i' '1 F••.r
'�iyr 3i i ;x.: f nr�' J }r_r: ,?i1�. �i"+,•�``;, rsy':v `eE-C' •i-C,f/v •T. 1 R v -.t 1
1 VON
I '�? ,'�i R,; ia. 'i�. �7 :.•': C4: 'I S[ • 'tl'r�s it`
i L - r • �-., _ .1. per
r. _rr -:I•,l. �i}•, 'r, s-y' J•,iY�-.-,•ti' 's ,a. ! 'SL.'.: !' 1a1 .,, ,.,
't� � / :t /1 tl,, _/1 J. .�, ! � /(� r,.'S•t�-�irr; ;�' "x �'�'il�::.'.. .1�da' ���.q� .+ - ..
r.i•�,:, 1• + r' :( ,q�r�• ti t�' SS{+ S 5 ��J r ,r/ l"eta �r� � ,.�':1 . �V:. ti., :17.'..','1 a Wai�Mo!r-`i
-'x,i�:'J� i 1s.•+f tr; FaJ''uJ r r +: { I ♦ IO
%
r� SrF /r.i ti• .�v_ 1.'r St � F�:.�.e rJ'4r "`y e�{ti [. tr /�� ,� ;: }i Z-
} t'• •; t:�. ,1 rll +r S.vrt T' +rr ti.r 1.,.�+ .1i �1i �`�•-t•`•. i 7.r,'�r`a,,.� f•r •r,,y`' `-.v..�� 'rr.,�:. >����
-1 : '! - 5 1 r' 'W,• ., .I:�l'(, Fr{ -],r.v 'rah .'.atA s ,.l'<.+.!}:aalY�'"•• F
�s,
-:s.r � r .f:�',,," _ .•r' eti{ � t- !e� I s :`� r 1 � 1' t� / �,R y � �,' f���'
";!'i? i•♦, • � : ' h 'i ,'r: ' M-, v� rS::�� r �� � 5 J°e p �, �'rr• si .
�'-, 1 i n� ,. ,.�,r ; ,l��� - ,vl�' `{ ,.� 1: -.P s, 1,:'s,.i w i' yi;K ='ov sf • . f , r } t -i r, -til .�r .� 1 .r
r! a <,, :aa .• ,s v' +!e tiw"+ ix �,' :.J� � : r, t.fFr'. � JI �[- i. '1' ,�� y �. J. .-�. .f. j-,
^'��:�i` �� °•,iltib �r� r' kJY yS''. �. ,k�t. � -'r ,�l: 'L`{ @ If.! r N�iSr ,s' ';1 � it ' `�;,: "9t hG, .t..�'��i .i� ti�i,. r..t. ,:!! '•+.,� ' e -
•,, ,... ,~�� ,ram,-� � F a r,• �r►°�;"�'� ���� h, ,>.,� ,,, �. ,,>�� •J�:,[� � .�.. �+�r� I�.'�,, � � -� jp �.� -4 -� .�� ,�
�� �f3gt 'rak' , t�h"+ aj0`tia"'j°p _�,v .i"'111�'F=! f'K' vi,3 ,!'' � ��-s,' J r�I I' �y;� r r•a •: n,rV ;��!ri ,i�}. �l.�r .I. ly n..;./"�h•...� .!
7/' 3•C ,[S �g �..{!�� yf r J 7a!?74 �;',yts",7'1 \�"r14 S 1 ! r . ^��. y` 'X,', r� i s fr�+ � �`.qi.••;.� 1• � p ' ��,
-,','� 'Y': `�::r:• p'-�a e -1 : '£: •• 4" y .�- .3 .X. t, �1i[�•', ,`I:�.,'�. "� 1 0 . r: / l . �.'
4fi. �1t q,�. I14 �.gFlp Fr' 4 J� ra'r ,A,y se s: .4
i•� �:.:.4 .�. •��` f �'r{;'� � -+ . �a'i,f-,.� Y t., �+'\'�,.,,L.:�,� 1, 1 '.,S ..)r'.�lr r�� "j" %r 1-:�'•t', J� i 7, s -s. -t, :iy' �i,
�a. ,t.`S {'[--+✓t [ p� r; ,1 ,,, ri l,' i. +y. s, si '•: r. � .� r i. r �, j'
:Pti�. { '�'""+.' p':2.J1 'r l7 r ►y�x��(/ ,i �,, .5 -r r, ; � a;er.. t ,4+ �!S; '.r� ''�! s' d,�G',_:"� a ''' s .:.� - S , f,• \�. .. �k •� r, fiS,r}i:e.� 4' +4.. � t�c�� ,��,r :i, r� '1.; l .} :.i.•�;: ��r1'. '� %, - ,'h ' : � ^') . s '
_'J� � ,�'ti ..4- S.. } `tir.- ,S'd• ra'i[, r t?" i111'i 1 .1.. .1:�ak• t r *,C� I s S •. �: _t' � ''a .'�; ,•1 ' % �t
IN
f i • 1 :+•.:'•r. t ,. rs ::n:r J �r:•r i, �. '.;', nr, _',;': '!,
•:. .i,: '.r•s"-`; � '�.'::ps'. .j,i' l ,i ,,�f
� :/S ,sr(.. e�q� }I' �`�� l.''.. 4 r• 7ti$� :r�'.'J.�
[>h[ ,.._,'. f...__,..?.fh.Vktlrkf.•�'`;. '•"wL'T>``T fit. :�h_ - 't�.in - ERi,'n+..7e/ :�% i. ,...' S.I is'[,. �;[s.,l•' �,T1'• + mir':...t r�',.

44
On
3Q00_ANo-3_250--SER_ _
3 — SPECIFIC�ITIQ_N_ 5 r
K - STANDARD,
Al. ... NiODE� 'AXLE DIAMETER LENGTHS t
AVAILAeLE".Atr:
96
.r
r Y �Yyvim""
p =fix {R..a!s.�F,�O-•F.c4
POWER f=QtnPaaEt�tr —
77
-_ta'ST'lf'.-
'. STAND
ARD FEATURES..- _
Honda A hp. OHV engln8 'Single Cftitt drjVe on. drum ttsincl
r _ }I
Stewing ring ttamCabie 3i6A{T)►' dtityt 1TgtCflll,rt�; '. = :'
x�r85t Hitch Tool:$ar - High flotation tires 3' x 6' fufi6 itain+§s
—•-4-gallon aluminum fuel tank" '� - = fiats of psin -
:'- Automatic guts can Stop • Best duality 24t76 medium' densittif
" ^� :.'. Hose build-up Safety svVlt�trr hose -
_ 3 wheeled high clearance gu e • Ge-ar driven tolescopic:siabiiizers.
} ` ■ `' ' cart and towing Bevis. f • Disc brake to Prevent hose rail.
' Nelson SR 150 Gun.: z • V x-25`.feeder:hose
a `. ■ - Lift kit for gun cart. "` •Mechanical speed corizp9nsarinn

Mimi
:hmi Td7A
7�
160'
120. minutes
13_0-houri�­
270
JQG
0 860'
AS Y.
100 nWndms
ins
850'
280
G.-I -
90 mh)Luitea
9.1
85T�V
2
-280_L
Al
75minutes
-A-__
---
7.6 YAL'
At
whoia po (XmUnUOM LM Cadman po,�pF f.`d��wt's 43 years of leadership and
=4 1,,* 61 1 —11 , _ qu. .
or eiperiapcA ih,desion and manufacturing smndt behind
every Cadman Tb&cftr produced. Axompiete line of
W PUMPS, pipe andaccessories are all avaRable from one
CDMpany_
mWEQUIPMENT
Epp INN1ANt ACF=TURALr,UACP&HERX -ADRRIOAIION.�10Boi-Cogj*.Uiii-O*&Ao'-Ctnid 41
4

y Q
�l--i9S.'-
FROMWR
= -- • -
-2-7
-�—ry.._�s • _ - .:
i
v 7 ,r With the cn,,�ne n�unin; adjust the pulleyoatrol knob until. the speedometer z
-.
uired_retiiev.Grate:{.frairithe=pevioiii=stems
Nil
TJ
=NUT1 'i3icsomeoer: reads^ttI�e actual�s eeci0a e:ba(Ystrr of host
-
�, , , .-'. , ee retrieve rate tis set
br checked on end third— o o ith layer, the iegttu+�d retrieve`
Y = rate must be adjusted to the "corres.�ted value"°for the. layer beingtoaded aI the tune °' Ttus is:
" y' s01
�sasily one byfrefeing to the chart attached to the rnachrne next to the speedotnetes. 'lsg
} "carrccted value" u rCa.directly f77
xom.thc speedometer - =
�rou are unsure of your retrieve rate'for, arty reason, manually crier :the .i rtrieve rate by
uriag the lxosc movement over a tree {3) miileite period astd average this measurement
(divide by 3).
9 Qpeu the access dogr and engage the disengagement pu Close and secure the door.
_5 J/�� 7r a' 1� 7�
V-FuAI�/ relea= iIIii bi
ma', w' ".- ' _ __-,.. * ' � - �'-- r _ 1`�' _ .�.. :�-_��-..--mot•,+--.''h---'_� ... _
- r 1 ey,,., a thorough vrsual inspection ofthc ofthe machine's function to ms= proper operation
_ - re Iea ' he'tna a cnzat�eaded - -
;;- - —
�+ 7�'` MPL.> :�F= EVE RA?E S)r.Y. L i lUN
-- - -
x �3)eterrnuie the retrieve rate required to apply a 0.75" application to a field 250 feet is width. -
A, 3250 model -Oaveiler is fitted with a Nelson SR -ISO gurz.':The gun has a 1 18"-rutg nozzle
` a1� at 70 PS; ,
- — --- -r --'r- - : r-� --
.!, From theNelsoa.gua chart, find the GPM you are -um .. under-the_4azzte-sizeyouu__.
Ve in. the Sm. Thc shaded block under the 1.1$"ling nozzle coluini you that
the gun ig flowin,,:,243 _GPM.
From chax #4; deterrn na how long it should tales to cover'" 6 { 1) acre; in minutes,
by crossing the GPM ( from above) by the required application of 0.757 Th shaded
} block tells you,that it shaWd take 81 ;nuiiutes.
-- - --- - -
--- From chair.#S, determine the retrieve rate you need, to obtain the desired application of
4.75" by'c=Sing the tune r aired to cove one acre 81 minutes) b the Iwo
s = $0. feet 'The shaded block tells to set the hose rethev& rate at 26
pacs� (: )• you __.
inter cs per muiu c as a stalling pouu :..
L4r " • The gun `sboald be set up so that the 250 foot width is covered plus sufficient overlap
" _ . , : F` ;:.. { beyond the edge of the crop) to provide adequate watering at the edge; bf the field.
_r * 7
�YOTE' Keep in mind that the charts are to be used as a guide oat}+ Always check the actual
application rate wnh rain gauges to confirm that thbrapphctivn mite is correct:Ak
. -

INUTES:REQUMICD.-TO-WATER-ONE(ILACP.-E` `
----
--PRECIPITATION RATE.( ACRE INCHES
.GPM
-j
90 135 ---,--.-,:'_225
'-
m
-270 -315- �iM
'2 '71
453--,�
�,-140i.,T
42
216'--
--`272��-
isS;fwt,--
350
9
..A.] 4- - "A
19 AW'-
136
170
z:4'W'
< 15 30 45 ` '60
'105
120
157
Soo:
4' 1 42
r --136
550
60
4-721--
96'-
."-.,.,-.123!,x-
-.:600
;"22 33 4 -T:55
113
650
:10" :"20 30 .40 50
6070
82
104
RT- iiS'--'
RETRIEVE RATL-LANCHES PER IMFNUTR
T ,,VANE SPACING (FEET),
ACRE
225*-,,-.-"'
250
275
300
.139
4�
-107--`T-.-.-.l
10 0
,20
13 1 —1-16,
-
104
.95.
:87
80
75
70
.65
-on
3
-84
76 ...... �:�
70
60'
-,56
5
70
'-'54
507=-- ---46...-
35
75f-w-7
6 0
-50
46
43
40
4V
-:52
-4 4
40
33,�
58 2
46,
4
39
3 6.
Jkx-
"-52" m.AW
42
38
35
32
28
26
—.-48.
-:29
60
35
32'
29
�7
2 5
23
22
7-4�6::-
32-
29-27---
-...21
20
.-70
37 3:z--
30
-:`.;-27."
25
2-3
2 —
20
19::'!:
75
28
25
23
21
19
17
--SO--
---33-777='T729,-, ��7,B$fi
20
17
16
85
25
22
21
19
16
15
90
-292
23
21
19
Is
16
15
-7
.14 l.
.100
26 -W,
21
19
17
16
15.- :T;
14
13:j

J.:
F:
�J.ORY
A4,
w
M
.kNOZZLK;
08
L RlN
.V
RING,?it.
I MGW
1WJ .4
MING.
P S I
�-DM
1, G PM
DIA.,'.'
--GPW-
,DIA11:
T
GPM DI&
50'
165,
285--�,�',:,
�1�52
5 J�i,,
�',300�
3
1255... 20
4��z300
A',,3354'�­
1+t'350-
110,,,
:!'143
75 �335
33
y70
120
270
155
290
197, 1;-�[.310:!j
ftq30..,
295 350�`
3�55",.L.
�165-;,
"-AIS
380
128'..
280
165
300.
ALW
1`015 360
9
90
05
290'
175 -
3
223
33 0
275 350
�335 31 V.
.495I.
390:
475
'109,k
143,
3DO
185
320 -
,235;
340
v360
380:
f. .405
J00." 415':,
1 IQ
150
310
195
3
3:
247"...:`
550
--.390
44 4
-
4191,
FS. 425,:.
52 1
'315 1 ,
7,0 4
33
'T. -, 3
40
45 -435
J:k.
:'NO72LE I 9.7-TAPER O'S TAPERI _:.,,k0.9 TAPER '1,.,'-`110;TAPER!,,'1i 1.1. TAPER-d. ��,`­;J I
DIA. GPM IA. DM'� GPM:
PSU -�GPM DIA. ' GPM --:?j DIA.:..."..'�,GPM
50
100
250
DO 270
165 290
2�5
'255 330
300
60
1
265
143 285
182 jng;
2 :325
275 .345
3361,
70
120
290
155 300
197 320
245
340
295 3 6 0...,
90
128
290
165' 310.:
.'-210
90
135
300
175 i 320
22. 1'-345
i,27S
-365
3� -.390
405­4
143
310
185 336
'.235 355
-2.
gp-
R 37S!
55 DO
4 2
110
-------
150
320-
1��:195
365
;'V i451
.30
�r
385.
as
-395.1
370 410
Af:
04 p�
351),
25
85
meterPP
Mi. ;4,
I
ie
-6 f CL'ro'w
42. ,
isa ro'ximattly 2% lc,�i r, r: tr;kjcct6 . ry ahgje
- r
and �5 /o, jes �'fbi the 210 trvd&
rformwoe data has " obtained under ideal test conditions and may be'adve Oly.. affected by wind, poor hydraulic entr,
Nelson Irrigation Corporation makes no representation regarding droplet condiEn, upi ormiq,,qr3.pplicaflon rate.
TAPER
_G FM_1 7'� 1) 1 A
-360
1:365; { ; 385 -380­`
41042' -475 -5I.
`420j 11t,500
25
446r, Ir 345
00 et
LSr NB YrGUN(!.:�'
ye conditions or bther &c tois.
y !.' I 11 T
i J., - ;j

mm.,D -aim Ml_ 'iy
K - mmim
3,s.
1..-.---275. 345'­
A-
-1w
�'80 :'I i_w 128 290L''_; 1$5 310..- ­1 ­­210" 335' 260 315 ­375'­,�,' 380 f 445­�•. 410'
Imp I
iloo- 355— - .425 'W
_4W� 't'w
44V-
47
7ki2o;� 320—i- 395' 385-1-- -42(r--- ­465­-44(Y
50
FUn J. Fling.Firsg
IAI-
ID8.
------- [0) 1 & PM DjkL
UL DIAL: -'-GPM- -DL&-GPM DIU�. �_ GPM­M-­_
60 110 260' 1,0 i:4'.2W 182 300' 225 315' vs m' 330
315 3w
So 120 2W IGS'-,: 3w -10 32W 2W 3W 380 3w 4.­• .4,4
100 M 30DP 1115 235 '340r 290 31150' 355 3w A 425400'IV.-
120. 157- 316' 204 "M :360' 385 465 420';" 545 AW'
R
Nozzle Nozzle. Nozzle Nozzle NOZZk Nozzle Nozzle Nozzle
1-05'12* Ix IA' 1.5. 115, 1.9.
P&L ..GPM 01,7_1 ...GPM , --DUI _ GPM DIX GPM Olk' GPM. DLA- -GPM—DID _GPW_; DLA-. GPM CKk.
70 270 360' 310 3801 355. 395'. 415 4.17 4W 43 555 - 450, 630 46T 755,'L 495' WA 515'
- VMf9W�1VWt 470�!P 75 _-f;FSO A.
90.1 310 39V 3W 41(y 405•L: 425. . 475 445, 545 465' 625 485' 715 !ws. &%S, M' AS m'.
ags —445' SCr__ GW---49Y—
md . . . . . . . . . . . .
-1-30. 370 4251 425 445, 485 465''SW 48W 655 w' 210 62W
515' 7s5 IWO
Mm 7-1
L
(1 aid eclu (1,74' &CtuA tljw,aaua
JIPZ ad �a' G"P-M GPM DW GPM, �:-D
91 f-V47D :5 Ow %
.515 695 425'
It; Aws 440'
370• 380 NMI. 515 440'_ t-590 AISS' t-:490
7-A 05
425'." 14451 57
..3 i"' 425 Soo 5 465- 660 480 755
sm
WA -ftS 40I tV=17
*�-r ---I 7W: 4�
465 re�W445t- US 905 -
63C f4s"
545 0!O46�1-1-R- 1 485' 725 500'

7
Gase Speclficati6ns
- ----- D_-22WI
n
Ra I
larnIna
POTVC PI e
77 d P ­7.-7
-ress , uref
g.5.
P
nv lit
�VA,p
sibns
&C;Oupj6r_
M
...........
g
E,
— - — - — ----------- — — -----
­4 alb
611Z
6&s�ga
.........
;f-7
kemo_
_7
jj�ents-fls.. rr
h j6uthing
P ealing -
2Chevron- seaz�
C_
'd
_7
ea
3.-C ur
M­­ prov
ornpressiom,
.
vacuUm.
d
S
A. Wiper bead§ to clean p1got en
D2241
Diamond'- AST�M
v P.- _.c Ri P�
d—
ressurb_�tRate.
._-IpS -nt nSIC
Dlme
01
'-Gask6te
Riebe
Q
A
0.
Sc
r
DZ'
-oc
Gast_R
31 b 6'
7�.
6036- 0
77--­ B
'.LL:_�_
A
So
Pipe ckcL E
-16.500'
q, 0'' Size insert
0.42
-500 7..
121.762:,-
0
.91500-
77
14.952-�-- �4
1-2 3
A 6
6 6 718
314
5 in
-,D-2241' PipM englon
_'L�MinimtjmVldall-Thickness
7
bA.7j-5 SOFk-.1
SOW SIDR-21 SDF%'26 'S 12S P5' '_ P51
20OPSI
DATE 3-1-88
PAGE. 2-02'
SUPERSEDES
Curve 4117 . Paae 2.02 1
Dated 4-1-85 , I
M I C. I PML 11-1863 Remki- H-18153 VAR I OUZ JLP.M. C C18 ko. q:2; C. I Pam L-3001 Mckmw, L-3039 ww. 13-1/2" TAL&L W f0vah 1.1" .1
MAXIMUM WomKivea PftassusE 247 PSI h&jq &&go
6&
30
20
0 ji
TOSL
0 100 200. 30o 4400' -560 600 ' 700.-' 800 ' 900 '1000 1100 1200
CAP*CF7 IN U.S. OALLONS PER MINUTE
C-7048 T-2554 C-7048 1D-27-7t 3--29-72 MOOELB,3JQE3M
3ffOj*rjdL_LLC.I. PWtLF&lL_._H.=j93q' week"&' H-1939 VAw1cv3-. JLP.1L CTCI-
wp~.- watudd C.I. P8qLx&. M-2319 mocKY& M-4621 7W 10-7/16- FULL T.O.&L im *"h -~44
HAx%xvm:VoPtKim* PotcssuRc 266 PSI 1r4 C9 A" 0
3D,
40C
ra
.840 .109 062 =
350
.060 Short "'FOOn
0
am o n d a 7ju
-063 j-ti-on—tur,-1
.,.133 , 056 -1 S p ec i f i c�.
.()64 7­
.079 -' Pipe I .140 PVC Irrigation
250
1
45 A 13 091 1 �3 1) 2 24 1 - S D R 4 1,3 2. 5 2 6, o r
.154ASTrA-
2 .170
.137
mad 200
2 V, �t875'.203 tion-Pipe S �1�c
,135
167 Diamond PVC ITrigal DI-784 Will,
3 Ig to ASTM
—2-14 43. compounds confounii Dianjond PJ
A36
... " ... I 150
.214 r. PLI , n of 12454B.
5 265 2 11 classification stm - ll'itic dimcnS10I
.316 .255 c ect. a
Irrigation -Tcqv1ircwc 100
-igation PiPc MI) ntS--ZS-out1fl
6 L'. �.t
.332 -and,phys 'at
410 _.chemir-ai. -ic E
8 6Z.�..322 262'
.413 D2-24 1. -Annex
.511
_10 5 -- - -- — 'z3l 1: in ASTM �J-cd in 20 1
r �qC)
06 -DD. and
50
and SCS 430
12
"I laying length,
O Ih
A PV 'lie( 0
r;
4441:
4.
..........
-Ha.
4-
- -
4.1
A.
f
.17
L
4+
T
T
U.,
. .... . ....
ILI.
441
_2400
AM.,
sz:
Li4j4
+
.-A
+
4-
T
4..;--
-i 2200
+
tfj.
.1..17
WI
R,
t
14
-d-T4-
2--i-im—L
+
A.
++1
H!
Ef!14
THE1.
,
t
t,
T
+
4;
44
44-44,
j#
+
j .
Iq
T
-4
j
T
4
�Efllg
Ion
11 MO
alm
Al
an"Niffil
MEN=
N
so
ENE111
0
�o
nmm""M
CmMemm
OWNER
ONE
REM
ME
MEN]
IBM
mffin��
S
MEN
OEM,
0
��s�
0
WE
M
NW71MM�M
ONE
wo %* low
r%aLV
Onp
Lire 0 3w 400, 5
xpressl
LHOW11 ts of ASTKD-3
gjaquiremen CAPAaff IN tuL aALLoms PEA meNuM
c-6695 B--d- T-2075 c-6695 5-29-72 MODELB4EOM
20
103
2!
of
0

"7Z ?
� Wm_
WM
A-P4,,
g
..... .....
7A
EC IF I CALL- I M. I, rv_2 5
U-N b,'.0 A'
. . . . . . . . . .
NO.
A
.k9
-12454
-S B :(1-120)
PVC PROPERTIES OF PVC
-rate pe. 2
--a-DiamonGIP pressure. '�'­
Mininiurn
ffif.ough .12-) i s made of compoundsm
Conforing Property.A S fM
J 10 material requirements of ASTM. D2N 1 in lest
1 40
accordance with ASTM-- -Specific Gravily D 1784, The -pipe-.sizes f) 7V
-th(Ctoh.­12").are -:rnade. (a
I 'T6 nL'§jfFSt�&gth, psi 7-D-638
7 .000
vihich- —a-Lgasket jo seating in
-Tensile Modulus,--p 400.000..,
-accord an c e-, with i e. requir6m­entsL�'df —AST IZOD .a, c . i'Sirenglh_ ' D;-
IFA 7 for solvent,4cement.ing
1ht6gra(:.sockets%:..
h
�s,.e j5f :95 b&j 7
, 70 M
b2672-
l7+amorld IFS pressure -rated P� pipe ­meets a
AS
. r . e , q uirements as ou.11ined in ASTW D224:f:­ S .- ul . f uric Acid. 43
3 01: 0 D 5
Da
ys Rotationi
AC �
h---m eLe n d ---s halk- be--I)e v el 6d__19;�tifat e
or 2° C
ioinjng'.�.and'..referencem marked for_
depth 'of insertion. - Diarnorid-A0 . ff)'SheO Change in.-Weigni
,roper:,
`".,!s to,.be used s in 'Flex Strengl J;6
.lubricant _b in the 'oini�g.p�6&e s.- h�' 5 .0 10 4 0
Change.
J .'Diamond IPS pressure-saied pipe 'is:"St1fJ0l
iec) ri. 1. 2 3 0.. C ------- 7-
::20400t- lengths..
sr ..1 0 [C. 0
Change in Weigm
%
7 C.
J

A X16�
`FRICTION
iLOSS. _C14j-%1
&
E-
3PD1AM0ND`P1PE
V,
.1PS"D1MENS10N:'_',-.`.
Inch 8-inch 1-0 Inch12 Inch
A."
4 Gallo,,
FEET
Per Min.:­
, �L �
`I'W FEET PER HUNDRED .
FRICTION-0,D0sl
777
'd
150.
.160.
1-7-
M_
S,
Y.
RIM-
.7341-e-
%
.-2.28
'.'9 5 ::-:-.40 -- - ---
240' 2.67:�-
0-- -1 1
.46. 12:
-2b 3.
0
280 3.56 1.26 .54' .14
300- ':-4.04 1.43- .61 17:
7.
_­340-' .82
360....'-:5 6T�--_'- L2.02' .86 -2-:- .24--
4
26,;:
380 -'6.2 6 �2-22` -95
t7
00,- 7,
4 6 90
�'45
4� 0
7-,
2 92. 25'�-�t 'AT -
0 ':-3
3.18' -- - ---- e A 2,% - -
-14
-.5 8L� 437 5- - -.060­
4'500 _7.
1.89 -52 .18 .083-...
600 2.22' .61 .21 .096.
�'650 2.58:-, :..7 ' 1 -24 110
-7
77-131-77- 25 -7007-
7 0 -3.36 --.93- - 141'
104 00. 3 78� ------
--175-
AT.",
00. Table -basqd.(jri J jams_-,�,',.4.T!:-- '30
_Hazen7�W j,
.44 194
950 -CW - 9
eq ua ion 6.21 1.44 .4 .213
0 5.73 233
:.. .
10
To find friction head loss in
1059-- pVC-pi havin --�rtj 'jrd .73- 59--
W g aifd
`7 .1100 dimension ratio other ihah � 2 1.88 .65 .276 r
1150 the values in the table should 2.05 .-.70 .298
..:.,.1200 b e m 2.21 - .76 .322
_Q p jpd
.346
appropriate Conversion factor
.'-'�1300 (F) shown below: 2.57 1.88 -371
-:1350 2.76
.95 .397
295 1 ni
42n
4 0 SOR 'PR F
5 .3.16 1.08 .451
N
A50D 3-35 1.15 .508
21 200 PSI 1.00
�A,
26 160 PSI
00 .91
-700 :84 5' 26-PS ( ­_ _­ '
.77 _!-1.7. . ..1.45 .632
41 _100-PSI.
800. .7851',
162 .698... ­,
75z`19-
79 �.767
'0
190
;200
220
.84
,
T
0
t 'hd.- -:z-
Wbold line indicates velocities in:excess feet ex se
whichesr`exceed 5- eel per second are mended

-
1 W
FQ
STALLATION;, '
L ' Table OF.sG'A[rT10H-O► LAtCFOM ENT ASATERIAL' CLASSIFICAT7[IA-S '-
�F-:-Dianiond Agricuitural,.l'YC,PIpt. should 3eassernbled and
installed with uruforrnand.continuous_suppart from.a firm ,
basein_accDl`aance with'the instaliatiori=procedures=provided —`
in ASTM D2321,and'the-lnsrallation Gulie for PVC;Water
pocket sized" -edition is -available, from �-your '_
rcpre setitative or from Diamond Plastics CorporaLon
:Embedment matenals arc to.,be.in-accordance with soil:.-:
lassifcatlonsisted under-Unified_SotiS].assl£catton
ystem KS-T D2487_an TI 73�488 y
w Te assemble rlcan mating surfaces of the bell Aspigot and
asket'lubricant furnished -6 Diamond
PPYg ( Y _.
,;Plasiics_.Corporation) to. the'entire'spigot citd..up to the
iefe'ren
cc mark .: Also, apply lubricant to the contact surface -
Of the gasi.et :
With'ihe'ptpe"in:`straight alignment. push ;the spigot -into
the bell .Up..to:the.insertion line. if -a pry bar_is-,used to
-- 'apply -force. the pipe should be protected by placing a board
between e thbar and the'pipe
If norrfial force does not disassemble the
complete theJoint,
oint and examine the parts to make cc�:ian they are free oF- - -
s t
�-
bs r cto Tsuall nspect-tlie compietc djc?intYto insure ,
�the gasl.et been dislodged.
i y
-
SOIL
_ �rOrxCRIrriOS O - -
CLASP
TYfE
IMATERIAi,_CLAStIrICAriOS
Ci.n l S`I.•
-
- ---
}Swfrn.d -g d.. ir.wdr iwwa.:.t IN » 1 in iwh : it s. ad .....Y .....:,: =. .
r�.rs:.Ad'k-r<...[r_swx_ - nrr.n,..,..+...+. s...[e.'
rr.L r.�►.+ stag. a:.d......er.n.f.d,�Prlb. - - — —
qy�p. wry,.:
CW
w.R•I:.dsr R..ek.Ar_l•ar�iI"-�.: fre►-}Ir{"�w..e .d -.:_=',.
9}14 .red Hw. YSI.rti.r
-
... -
Ck±ti--
_
CF
h«yR'd0d rr.rr6 .wd ,v..sl�aM .a:i,.rr.. 1•""•- ...r .}ai .w .w+e .�,�
Sw
-
'k.nr.r..s.,+n.arr.+'•Mww,9ii.n.+.+.�lr.�,..r:.tl.+. --
r,.;:-
-le.rti prkd ...d.a.d rrieArJ.4rvlso= r u..r..-!wn.4—
—
Ctw UI Y+ Nk
-- oa -
-S.h1''v!�'i'+•�rl.w a.► - •w..t_fOi'w. �.:.e �r r..r.. G r..,.r+l .
.•'
fr l a .ierr. Mrr sA...S1.CM -d ... H.. '4#1 _
CCi
Qafry t' k•FrA.iwJ'A+r M•i.w.rr. :W% �...r .lw a, s.�.s.++•1
Let_ M. a— [e.G. re....ed r H.. �w ,-
'"[`:F^
SM
. Sdp �+. iswd- d— YM ".f f..r... : lr a ..e.e-
-
SC
n.lry .A.dt.war,y ..•:. ►6.r Hu. S.re .r a... � �.w..::M
M.af. Mr[ i.r Sfl'i M....A a+,r.- 2M
Clan [r.3_b
►IL
I.rs.."c s;I . rr•r r -siw. A rl....iky
,�
soa «lea.. sox r w.�e.�...ii w. 7.a..:..,� •
CL
$-.1p.. d." ar f---.:.....f.r.,da.x'.y, p.• k. r .... .. �-.. s.y.: '
k.. rkls Lkr,;d V .;. Y1% .w I... i.ly .. �+r i`^^''' �•• •^'•r
COI
6wl.wr.il.,,,.cr.o,....r �15�.+r-a�L.r:wl.:- Jw'r1.......r- 1-.^i.•,
r T hitkPI 7-0.r1ey.', .yrr w. ►.. r-+
-
.1
MWE
S-,:Y-Y,-.'...
+[.L TM wSU7s17_t«ep Gw CAu rw..rr:.i �iw+wir:+r.l AiI'M
fwYWMdr
�;! - •' 1 �� ay�i"`a
-.;er"ASTM_-O 2fS7:-wl.-ri1.-Sg ...�7; H
_�-
..r.m.i[ [ l.a N....f l'I.sa
rb w . rF pr.
-
,R f .-.:
Table
APPROXIMATE GUIDE FOR ESTIMATED RANG C,0F_DEGREE
_OF CO�IP_MON VERSUS EMBEDMENT' CLASS'AND SSETIiOo
-�-.
T hG haunching area is most important
to support of:.
Of PLACEMESTAS'PERCEA'r OF'STANDARD-PROCTOR — —
- - DF 'ff OR RELATIVE DENSITY-::: --'- ".
.the
.. _. _
P � glpe.-For good support,-the-haunching:area should be-
'FOR'GRANIILAR MATERIALS IN PARENT
eompacted'to the, densities given in'.
the- Long :.Term
^_
={
;
CLASS OF EMBEDMENT
t
tl .
III,
Deflection Chart
;>1V
„� ,
_-_,_,_ _
- _wwwArKnow-
-__ MwTEAIAL OESCRQTION :
rimAar
Said a.d Grard
-'-
Mired • Gran
Fwe Q3;a
---,Per.•:.-,
--. - -.. _- ... _,_._._._ _ ..,
-
._._... ._ _-
..
-'WlSrials ...
sous •Ck..l __
'.---Sala-..
56i1[__.
�_-------
-
-
Of. wwimrs ca.rai imp
9.12
- 9.19
- 610
-
-�
se.l Ca..W .b. wtod
i of Ptce" (orAdair:} Ou.ti.r Rari't
_, . - - pu..n• .r.c...p.
-----
C' _?l' W'w P?'-'---
95-100
95-100
95.100
90_1p0
] .
_
�:.
•�':'-
O—dy►Tw—�'°
•..Ma..in;_'.
f49]
Ido-75t
IQ}Y7
edb r161
09S
75-90
[.rl; �:.-�
'/
� .
— CMf01.d>•[
"
—
.i,
- '. � d FCC '� ._... -
1 emit
tin �„
- -
yy
,K• �: :. -
.
s MFl•IH..t...1
1PEEi
.:n
e40
Ica.y $1
rQlrO
GDxO
eon
taFMII
t ef}7S
/-:::::.-..`
4404M
Iwo?
-
fUzi
�F �7'l.0 .abk'�tr. 9rllalgd.a.[ Swde drfw.ns a.rraCr_ 1+....r..lr w,i ilu.rled U.ia�k:rr
1.-111r11.fldf YrrJ,�sw.d�dalnw Mddk.rr[W:[a..r-1 Ut Warn led M.M.-de giawkf
-
�,F`-,

coated fittings
be fab'r�icated in- almost any configuration. ..Same epoxy_
stacks and fiyd�ants;Fasgar� integral part of -tfie f7tt�nc�.
,� a =to steel
4ccasiona7�y ,jt may__be necessary toconriect PVC,,' plastic.pi.p
a This' connect�on�can� be. made- wd th. a -coupling ca] ]ed
h nor CAS P P
s h, In line va]ves can be suppl'ied.uith
- ;trans i tion :or. r•epai r coup, 7 ng
- r , _ .".
=to'gase. pa c_
f _ Thrust. blocking. -Is --require re.quzred for "gasket pipe ..Most thrust blocks
,t
wi]] be concrete 14anufac urers r.eco_mmended=ti�rust blocks At
any
than Figure gives an example of -
changd;!. direction greaterx ---
;'differentarrangements for ,thrust 6locns: t
ag
F 1 - — �A !, k1 � G+...A �j���.'f If.r'.Z L:•' Mr. ^_ -}<�- _ r.y '.
4.
4
yr
krr
$ c
1•�s y - .:L�7y l •,- r''�'-. „-�- 'ter• c
L. -
k_ _ _
IKI
Iww
,.".fir - -' " -.-„ �._ �• '�• •, - -- - ------:---�',' .. _.-..._............ --- -' -"-
t
t 1 • -
-.mac '�,,.. r•-_. ►• ..
zC ;
fi'gitre ' ''Example of differen �rangements fin hrust blocks. --
-. A
tr

{
r
�,y, 5 2„ -qn• ��' .,1, s,s „ =1 sY•-1 � " 3 ' T'y�y?�*.� � .r -a. ..,„c .
n
_'.:,.: _ram,.-�-`:.`x-`'.' - - r� _-..�--'.— •-v- _ � .
-x,♦♦+ y r _
al�f,•z. '. MBE' ( y-'Y _.-? Y - ? _ a'• 1.
'L ♦ •'I " - l� hihil••� r • _ -1 t. w.i.)..4_if
i+1«+f Y• sM _ ,fo:....0 - II& '-_y.d-E- _ Y A.-.r f _..: .-'^'*'•.' 'Y 'i r•.a+yi r2S-.
--Ti
g-1 r i 7F3 .2 y f `�'� x,- Jsr- • r w • f �, s " v*"-_ -x. t _ `r
- "d � nit 7 r �, J r - t -�. - Y- - • j �!� - • `.k�-ti.. � c.- ..,5 n
22
.� t- mod. N � � �., •'-�...�_ �� '� v�_� b _. _r'
• �s
'4 t-t:rF!!•' i - j-?(SYI:n _ 1 .� __ - yP - ,y`T. � - u 'f �'�'l� Ny IF• 1_.
5.tir,.t �f � .� 'ski. * r '-� 1`_" •-:rr ���.`��; �•.'r` --y; .fr F-' -
�.-�n ,lineival�esti�•r} ri t
-� 3° ure�2 AncYiora e�blocl.s forte.
�.yw-..—..3:-•`-r_�-�-;-.ra+--, .-ti•�i�... .:,1- :�'._ .� �T.a. ��:. � .:,•:-sib•. -_, °�-�.!
ab1'eIris tfre forces encountered, at en w#� .u9s ..o ca culate - -
s. T
`4 — -
-
- orces• encauered:'at bends, :tees,-,: and wyes mui pl jr-tlie f� gpre ,7 n
Tab _e 1 by the} -factors given in. Table 2.
Table:--1; = _-T-hrust_lugs _ _ - -- - -
r Thrust .in bs. ressure
E X s -
r 150 PSI ZaO ,PSI `�2Sa .PSI-
9• °� { Pipe Utameter. 100 P5I
znches
295 4-44—
rr +2 455.,580:::: 910
t..: 211 660
.. 3 985 1480 1970 ;2460
4 1320 '2720 3630 4540
ti., ;
.6 _...._ -_ _- __. 3740 - - --�600 - 7460. _ ._-9350._:......
g 6 '90" 9740 '= 13, 0d0 16, 200 _-
10, 650 1fi:000 j' ` -,21, 300 ' 26, 600
:.10 800
2 15•,150 22 700 30,200 37!'
14 :: w 20, 600 30, ,400 -
s- .,. 16 26,600 39;80, 53,100 ry 66;400 �.
K h_ • x•,

Table `2. factors for --.Calculating Thrust W for
66ws`a64 Tees.
` o Tees_ _
.:.. , ... brows-90 _ . _ . E1 1.4 - : O .l0 L
r
.-'------
` 66° 1.00
_ o
4 5
- r w' tir�?.r.:iv, 1. 1y. "•,4l_.�s "-V'r.Y - _,v/-=.?! .U,`Y.. _ _ �_
= a'
a
load for different soil types
�` Tabs a 3� gives the safe bearxz ng .
a
Y k = Table 3 Safe Bearing Load.
=-.,ter.- r ✓ r - .. . - .
si
F.-S -
- S
.... Tf.
Oil
Mulch, peat and similar 0
1000
2
s T
,. Sandand: Gravel „
3000 Y
f Sand and gravel cement
w
s
-
�""` bard shale 10,000
2 td= Thrust (Table 1 & Table 2)
`
:- Thrust bi ockt area t ft ') F :,. o� ear.; ng strengt a e =3 }
In pYaciii concrete tf�rust`�blocks check=wl;t - e-manu ac ur-erno_.:the
pipe`being:'used_-to-ensure-that_.the--cor-r-ect�ize. thr-_us_t_.blacics are
- -�
xx . _
bey used:
Tw= There. are a.. number of. machines that -can be used to prepare a
trench for, PVC plastic pipe. Soil types, moisture content, depth..
} r
a
trench_required and_.type and diameter of pipe must be considered. lows'
Generally chain trenches, whetT-'treiches; - backhoes or--vibra-t- -ng: p
-
will be,used for trench preparation.. The vibrating plow can only:be..
•.
used 'for solvent weld 'PVC pipe . and generally is limited to the'' smaller
iameter-of-p�i-pe�Jnder-mast—conditians he_cb n trencher or i�hee7 :.
-.-m trencher: will be ::faster .than the backhoe.. .Where wide trenches for arge
pipe are' required, -the backhoe will be most satisfactory. If so�iT
conditions permit,=long stretches of open trench will exile e.pipe;
- 4 installation. ifot�rever., if -rai_R i-s__forecast the pipe should be-a.nstall ed ---.
and the -trench backfilled. To obstructions,
avoid sharp turns in the line at
trenches `should 'be.`cj ' 6d •withi:n _1imits-. of curvature of the
t
. i-l".1 j-r-,
r 7.. .

I
State of North Carolina
Department of Environment, Health and Natural Resources
Division of Water Quality
'Non -Discharge Permit Application Form
(THIS FORM MAY BE PHOTOCOPIED FOR USE AS AN ORIGINAL)
General Permit - Liquid Animal Waste Operations
This application is for new or expanding facilities only. The design portions of the
Animal Waste Management Plan (AWMP) certification form, Part 11, must be included
with this application prior to the application being accepted as complete.
Application Date: April 7, 1993
it _U
..b_..,
1. REQUIRED ITEMS CHECKLIST MAY 11 5 1997 _ u� .=
Please indicate that you have read the following list of requirements by si our initials in the space p ovided next o eacb-,
item_ m
BY
l . One completed and signed original and two copies of the application for General Permit - • • d
Animal Waste Operations; �-
2. Three copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is disposed;
3. Three copies of Part II of the Animal Waste Management Plan (AWMP) Certification Form If
the facility does not have Part II of the AWMP completed, it must be completed prior to
submittal of a general permit application for animal waste operations.
II. GENERAL INFORMATION:
1. Farm's name; °. Pleasant Grow
2. Print Land Owner's naMe: _KpIneMU Arnt-hers Tnr_,
3. Mailinc, address: 221 Scott Store Road
City: Mt. Olive State: —ice_ Zjp: 284F5
Telephone Number: ( 919 __ _) 658-0746
4. County where farm is locat-od: Duplin
5. Farm Location (Directions from nearest major highway_ Please include SR numbers for state roads. Please include a copy
of a county road map with the location of the farm identified): Ftun K nmmyi le 11/903 N 9.0 males, tum
(Left � SR 15M Cx� 500
b. Prima miarm' N�aner shame (iifferentfro>�"L'dn�r)t �} g° 0.4 and to ftt a�oe ul Ieft
7. Lessee's / ntegrator's ame (if applicable; please circle which type is listed): _ "�Ftn Fc-ms
FORM: AWO-G-NE 1/97 Page 1 of 3

III. OPERATION INFORMATION:
1. Farm No.: (Only for expanding operations)
2. Please complete the table below as it applies to your facility using the certified design capacity. The "No. of Animals"
should be the maximum number for which the waste management structures were designed
Tvoe of Swine No. 2f Animals L= of Poultry No. of Animals L= gf Cattle Ng. of Anim tic
30 Wean to Feeder 2600 0 Layer 0 Dairy
0 Feeder to Finish 0 Non -Layer 0 Beef
0 Farrow to Wean (# sow) 0 Tufty
0 Farrow to Feeder (# sow)
0 Farrow to Finish (# sow)
Other Type of Livestock on the fargr: No. of Animals-
3. Acreage cleared and available for application: 27 ; Required Acreage (as listed in the AWMP): 7.0
4. Number of Lagoons: 1 ;Total Capacity: , 1264048 Cubic Feet (ft3)
Number of Storage Ponds: ; Total Capacity: Cubic Feet (ft3)
5. Are subsurface drains present within 100' of any of the proposed application fields? YES o NO lease circle one)
6. Are subsurface drains present in the vicinity or under the proposed lagoon? YES N (please circle .one)
7. Dees this facility meet the siting requirements in Senate Bill 1217? (Swine Only) YES N lease circle one)
What was the date that this facility's swine houses and lagoon were si3ed? 4ho'iq 4 „
What was the date that this facility's land application areas were sited? a !v
IV. APPLICANT'S CERTIFICATION:
1, lit Fcmag�y (Land Owner's name listed in question I.2), attest that
this application for Pleasxt tram Rm3ay #2
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be return tdlme as incomplete.
Signature
V . MAN
I,
Date 4 — 11 — 47
'S CERTIFICATION: (complete only if different from the Land Owner)
(Manager s name listed in question 1.6), attest that this
application for
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be returned as incomplete.
Signature
Date
THE COIMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
PERMITS AND ENGINEERING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUNIBER: [phone]
FORM: ANVO-G-NE 1/97 Page 2 of 3

DIVISION OF WATER QUALITY REGIONAL OFFICES (9/96)
Asheville Regional WQ Supervisor
59 Woodfin Place
Asheville, NC 28801
[phone] -
Fax [phone]
Avery
Macon
Buncombe
Madison
Burke
McDowell
Caldwell
Mitchell
Cherokee
Polk
Clay
Rutherford
Graham
Swain
Haywood
Transylvania
Henderson
Yancy
Jackson
Fayetteville Regional WQ Supervisor
Wachovia Building, Suite 714
Fayetteville, NC 28301
[phone]
Fax [phone]
Washington Regional WQ Supervisor
943 Washington Square Mall
Washington, NC 27889
[phone]
Fax [phone]
Beaufort Jones
Bettie
Lenoir
Camden
Martin
Chowan
Pamlico
Craven
Pasquotank
Currituck
Perquimans
Dane
Pitt
Gates
Tyrell
Greene
Washington
Hertford
Wayne
Hyde
Mooresville Regional WQ Supervisor
919 North Main Street
Mooresville, NC 28115
[phone]
Fax [phone]
Anson
Moore
Alexander
Lincoln
Braden
Richmond
Cabamrs
Mecklenburg
Cumberland
Robeson
Catawba
Rowan
Harnett
Sampson
Cleveland
Stanly
Hoke
Scotland
Gaston
Union
Montgomery
hDdell
Vdinston-Salem Regional WQ Supervisor
585 Waughlown Street
Winston-Salem, NC 27107
[phone]
Fax [phone]
Alamance
Rockinvham
Alleghany
Randolph
Ashe
Stokes
Caswell
Surry
Davidson
Watauga
Davie
Wilkes
Forsyth
Yadkin
Guilford
Raleigh Regional WQ Supervisor
3800 Barrett Dr.
Raleigh, NC 27611
(919) 5714700
Fax [phone]
Chatham
Nash
Durham
Northampton
Edgecombe
Orange
Franklin
Person
Granville
Vance
Halifax
Wake
Johnston
Warren
Lee
Wilsorr
Wilmington Region. WQ Supervisor
127 Cardinal Drive Extension
Wilmington, NC 28405-3845
[phone]
Fax [phone]
Brunswick , New Hanover
Carteret Onslow
Columbus Pender
Duplin
FORM: A1'L'O-G-NE 1197 Page 3 of 3

Animal Waste Management Plan Certification
(Please type or print all information that does not require a signature)
Existing o<Agyd or Expanded ( lease circle one)
General Information:
Name of Farm: Elgasant Grove mir-,ely #2 Facility No: --
Owner(s) Name: Korn Brothers Inc Phone No: 919-658-0746
Mailing Address: 221 Scotts Store Road Mt. Olive, -'NC„ 28365
Farm Location: County Farm is located in: Duplin
Latitude and Longitude: 350 06' 03" / 7r 54' 05"
Please attach a copy of a county road map with location identified and describe below (Be specific: road
names, directions, milepost, etc.): Finn K nUe take W- 11/903 N 9.0 rni.l�itr� left orate SR 1501 �
.chm
RdSbmp
St 1521(�t Sure Rd) and go
0.4 nd too fame a2i= cn lift
Operation Description:
Type of St+tine No. of Animals
Type of Poultry No. of Animals
7 pe of Cattle No. ofAnimals"�-
`
M Wean to Feeder Zt500
a Layer
O Dairy
G
..t Feeder to Finish
0 Pullets
3 Beef
D Farrow to Wean
D Farrow to Feeder
ZI Farrow to Finish
Other Type of Livestock:
Number of Animals: —
Expanding Operation . Only. "4s
Previous Design Capacity: Addinonrrl Design Capacityt'
Tonal Design Ca acih : YMgm
�
1
Acreage Available for Application: Required Acreage- 7.0
Number of Lagoons / Storage Ponds:- 1 Total Capa ' 126.048 Cubic Feet (0)
Are subsurface drains present on the farm: YES oCAO (please circle one)
If YES: are subsurface drains present in the area of the LAGOON or SPRAY FIELD (please circle one)
Owner / Manager Agreement
I (we) verify that all the above information is correct and will be updated upon changing. I (we) understand the operation and
maintenance procedures established in the approved animal waste management plan for the farm named above and will
implement these procedures. I (we) know that any expansion to the existing design capacity of the waste treatment and
storage system or construction of new facilities will require a new certification to be submitted to the Division of
Environmental Management before the new animals arc stocked I (we) understand that there must be no discharge of animal
waste from the storage or application system to surface waters of the state either directly through a man-made conveyance or
from a storm event less severe than the 25-year, 24-hour storm and there must not be run-off from the application of animal
waste. I (we) understand that run-off of pollutants from lounging and heavy use areas must be minimized using technical
standards developed by the Natural Resources Conservation Service. ,The approved plan will be filed at the farm and at the
office of the local Soil and Water Conservation District. I (we) know that any modification must be approved by a technical
specialist and submitted to the Soil and Water Conservation District prior to implementation. A change in land ownership
requires written notification to DEM or a new certification (if the approved plan is changed) within 60 days of a title transfer.
Name of Land
Signature:
ner • NMEXPyBrothers Im-
Date:
Dame of Alana&r(if different from owner):
Signature: Date:
AAVC -- ,ianuary 1. 1997 1

Technical Specialist Certification
L As a technical specialist designated by the North Carolina Soil and Water Conservation Commission pursuant to 15A
NCAC GF .0005. 1 certify that the animal waste management system for the farm gamed above has an animal waste
management plan that meets or exceeds standards and specifications of the Division of Flnvironmental Management (DEM)
as specified in 15A NCAC 2H.0217. and the USDA -Natural Resources Conservation Service (NRCS) and/or the North
Carolina Soil and Rater Conservation Commission: pursuant to 15A NCAC 2H.0217 and 15A NCAC 6F .0001-.0005. The
following elements are included in the plan as applicable. While each category designates a technical specialist who may
sign each certification (SD, S), WUP, RC, I), the technical specialist should only certify parts for which they are technically
competent.
II. Certification of Design
A) Collection, Storage, Treatment System
Check the appropriate box
❑ Existing, facility without retrofit (SD or WUP)
Storage volume is adequate for operation capacity; storage capability consistent with waste utilization
requirements.
R New. expanded or retrofitted facility (SD)
�1t11iEl1!/�
Animal waste storage and treatment structures, such as but not limited to co`1,irs �oons and ponds,
have been designed to meet or exceed the minimum standards and specificat{>bn10
,,, .r oF1<sso �•
Name of Technical Specialist (PIease Print): J. NEa1
Affiliation: fly fly RME = 14985
AddressfAbencv): l"O B3c 759 13me Hill, W- 2$458 .B 2Ui 6 39 B t. 4717
Si
81/11111
B) Land Application Site (WUP)
The plan provides for minimum separations (buffers); adequate amount of land for waste utilization; chosen crop is
suitable for waste management; hydraulic and nutrient loading rates.
Name of Technical Specialist (Please Print): M A/1-040 W4�sr�.✓
Affiliation: y Fataly F"rs
Address(A ,envy): FO Phone No.:(9910)289=60EKt—Vw'29
Signature:_ _ 0"�/ .y_+-z.- L•f_e.--,ram Date: Y�//�97
C) Runoff Controls from Exterior Lots
Check the appropriate box
F%I Facility without exterior lots (SD or WUP or RC)
This facility does not contain any exterior lots-
ZI
Fame of Technical Specialist (Please Print): J. NmI
Affiliation:' Fattt_ly l"'Rs
Address(Aaency): I� 759 1�
Si<_nature:
Eel
SEAL. }
Phalle lYo.: (910)2 39 E&. 4717
ANVC -- January 1,1997 2 "1"11151110

D). Application and Handling Equipment
Check the appropriate box
El Existing or expanding facility with existing waste applicationequinment (WUP or I)
Animal waste application equipment specified in the plan has been either field calibrated or evaluated in
accordance with existing design charts and tables and is able to apply waste as necessary to accommodate the
waste management plan: (existing application equipment can cover the area required by the plan at rates not to
exceed either the specified hydraulic or nutrient loading rates, a schedule for timing of applications has been
established; required buffers can be maintained and calibration and adjustment guidance are contained as part of
the plan).
a/�eu. expanded, or existing facility without existing waste application equipment for spray.
irrigation. (I)
Animal waste application equipment specified in the plan has been designed to apply waste as necessary to
accommodate the waste management plan; (proposed application equipment can cover the area required by the
plan at rates not to exceed either the specified hydraulic or nutrient loading rates; a schedule for timing of
applications has been established; required buffers can be maintained; calibration and adjustment guidance are
contained as pan of the plan).
a New. expanded, or existing facility without existing waste application equipment for land
spreading not using s12ra :irrigation. (WUP or 1)
Animal waste application equipment specified in the plan has been selected to apply waste as necessary to
accommodate the waste management plan; (proposed application equipment can cover the area required by the
plan at rates not to exceed either the specified hydraulic or nutrient loading rates; a schedule for timing of
applications has been established; required buffers can be maintained; calibration and adjustment guidance are
contained as part of the plan).
Name of Technical Specialist (Please Print):
Address(Agency): P-o,
Signature: _ f
tV. C-
No.: °11-c! AFf�; 91sib
E) Odor Control, Insect Control, Mortality Management and Emergency Action Plan (SD.
51, AVUP. RC or I)
The waste management plan for this facility includes a Waste Management Odor Control Checklist, an Insect -Control
Checklist, a Mortality Management Checklist and an Emergency Action Plan. Sources of both odors and insects
have been evaluated with respect to this site and Best Management Practices to Minimize Odors and Best
Management Practices to Control Insects have been selected tind �' �hulip the waste management plan. Both the
Mortality Management Plan and the Emergency Action Pl,A be implemented by tins facility.
Name of Technical Specialist (Please Print): J• Nett~�l'A 9
Affiliation: Fainily Fats a x
Address(Agency): FO BOK '7S9 lie Ili.] I NC 28458 = 14 9 c 510
Signature. ` • , YFY-- • ate._
G
F) Written Notice of Ne-w or Expanding Swine Farm
The following signature block is only to be used for new or expanding swine farms that begin construction after June
21, 1996. If the facility was built before June 21, 1"6, when was it constructed or last expanded
I (%N•e) certify that I (we) have attempted to contact by certified mail all adjoining property owners and all property owners
who own property located across a public road, street, or highway from this new or expanding swine farm. The notice was in
compliance with the requirements of NCGS 106-805. A copy of the notice and a list of the property owners notified is
attached.
Name of Land G%vner : RI)Erk YOM '
Signature:
Name of illanager(if different from owner):_
Signature
NVC -- January 1, 1997 3
Date: '1-1t -37
ate:

III. Certification of Installation
A) Collection, Storage, Treatment Installation
L1ew, expanded or retrofitted facility_ (Sl)
Animal waste storage and treatment structures, such as but not limited to lagoons and ponds. have been installed in
accordance with the approved plan to meet or exceed the rninimum standards and specifications.
For existing facilities without retrofits, no certification is necessary.
Name of Technical Specialist (Please Print): J- Nea Rl*w, P-E-
Affiliation: M2#y fly Fps
Address(Agency):_ IO Bic 759 Iaiee Hi.]1, W 284.58 Phone No.: (910)28)-r4 Fes. 4717
Signature: Date:
B) Land -Application Site (WUP)
Check the appropriate box
❑ The cropping system is in place on all land as specified in the animal waste management plan.
❑ Conditional Approval: all required land as specified in the plan is cleared for planting; the cropping'system
as specified in the waste utilization plan has not been established and the owner has committed to establish the
vegetation as specified in the plan by (month/day/year); the proposed cover crop is appropriate
for compliance with the wasteutilization plan.
❑ Also check this box if appropriate
if the cropping system as specified in the plan can not be established on newly cleared land within 30 days
of this certification. the owner has committed to establish an interim crop for erosion control;
Name of Technical Specialist (Please Print): Fcaig A- W2sbaJ13Ek
Affiliation: nrfa Y Fc y Famr.
Address(Agency): FO B3C 7.59 RMe Hill, 1C 28458 _ _Phone No.: (91Q) ter_ 4556
Signature: Date:
This following signature block is only to be used when the box for conditional approval in 111. B
above has been checked.
I (we) certify that I (we) have committed to establish the cropping system as specified in my (our) waste utilization plan, and
if appropriate to establish the interim crop for erosion control, and will submit to DEM a verification of completion from a
Technical Specialist within 15 calendar days following the date specified in the conditional certification. I (we) realize that
failure to submit this verification is a violation of the waste management plan and will subject me (us) to an enforcement
action from DEM. '
Name of Land Owner:
Signature:
Name of Nianager(if different from owner):
Signature:
ANVC -- January- 1, 1997
Date:
Date:

C) Runoff Controls from Exterior Lots (RC)
Facility with exterior lots
Methods to minimize the run off of pollutants from lounging and heavy use areas have been installed as specified
in the plan.
For facilities without exterior lots, no certification is necessary.
Name of Technical Specialist (Please Print):,
Affiliation:
Address(Agency): Phone No.:
Signature:
D) Application -and Handling ui meet Installation (WUP or I)
Check the appropriate block
❑ Animal waste application and handling equipment specified in the plan is on site and ready for use; calibration
and adjustment materials have been provided to the owners and are contained as part of the plan.
❑ Animal waste application and handling equipment specified in the plan has not been installed but the owner
has proposed leasing or third party application and has provided a signed contract; equipment specified in the
contract agrees with the requirements of the plan; required buffers can be maintained; calibration and
adjustment guidance have been provided to the owners and are contained as pan of the plan.
❑ Conditional approval: Animal waste application and handling equipment specified in the plan has been
purchased and will be on site and installed by (month/day/year); there is adequate storage to
hold the waste until the equipment is installed and until the waste can be land applied in accordance with the
cropping system contained in the plan; and calibration and adjustment guidance have been provided to the
owners and are contained as part of the plan.
Name of Technical Specialist (Please Print):
Affiliation:
Address(Agency): Phone No.:
Signature: Date:
The following signature block is only to be used when the box for conditional approval in III D
above has been checked.
1 (we) certify that I (we) have committed to purchase the animal waste application and handling equipment as
specified in my (our) waste management plan and will submit to DEM a verification of delivery and installation
from a Technical Specialist within 15 calendar days following the date specified in the conditional certification. I
(we) realize that failure to submit this verification is a violation of the waste management plan and will subject me
(us) to an enforcement action from DEM.
Name of Land Owner :
Signature: Date:
Name of 1lianager(if different from owner):
Signature: Date:
E) Odor Control, Insect Control and Mortality Management (SD, Si. WUP, RC or I)
Methods to control odors and insects as specified in the Plan have been installed and are operational. The
mortality management system as specified in the Plan has also been installed and is operational.
\ame of Technical Specialist (Please Print): M. Fenn Wasbm
Affiliation: Nlarrhv FanLiv lams
Address(AQency): 1O BoK 759 Rine Hill, lc 284558 _ Phone No.: 910 4629
Signature:
ANVC -- January 1. 1997 5
Date:

Please return the completed form to the Division of Water Quality at the following address:
Department of Environment, Health, and Natural Resources
Division Of Water Quality
Water Quality Section, Compliance Group
P.O. Box 29535
Raleigh, NC 27626-0535
Please also remember to submit a copy of this form along with the complete Animal Waste
Management Plan to the local Soil and Water Conservation District Office and to keep a copy in
your files with your Animal Waste Management Plan.
XA'C -- january 1, 1997 6

Ila-Im
� r
WL
lal
• h
: i
fS r'DMI
/ t
v i 7
bf� l.rb •� o � •'�
!u ti l
itL!
} oLvi
Lut A !
C� t sa�o _ s :i; ILIA/a
LM
L09-4KmKm
M 1� �! R+d ' * c
mz
-
i S 14 � kq
<d ci
t
Qw P+1 f :, Crounoad
.51
a? ? P.crsalf t.a
ChZpJ 11�0 903
L222 ` R ?d 1514 13 i T V `.k•
1 "tr was[�r t
all
-/ 1340
9s
P. d. 1379 / C.] sew ! ts�a v 'r
Raifvnd `r ' 3n
I6 y
1004
1700
a t
1377 D 90J I Sancta
� jf Z
�t Grow —ti
1700
r
4�
f

MURPHY FAMILY FARMS
WASTE MANAGEMENT FACMITY SM EVALUATION
Narno f5p �e�uEG.4 y /��T,v�zy _ Size Operatian ZGaa
Telephone
Location Data
Distance from nearest residence not owned by producer: Sc�
Yes No
Is site within I00 year flood plain?
Is site at"least I00 feet from a '"Blue Tina" perennial stream? ./
If no, site must be relocated.
,
Is site within I mile zoning jufisdiclion of a -municipality? ✓
If yes, site must be. relocated..
Are there utilities in the construction area?
Wetlands
Will site involve clearing woodlands or. any non -cropland?
If wetlands are involved., it is the responsibility of the -producer
to obtain all necessary p= ts. before any clearing is done.
Other Environmental Factars
Is endangered and/or threatened species habitat present?
Is a designated natural scenic area included m the planning
area or will planned actions impact on an adjacent natural
scenic area?
Is an archaeological or historical site located in the planned area?
Are cultural resources present?
t

Waste Management Ycs No
Does producer own enough land to property land apply waste?
If no, does producer have access to more 'land?
If land is not owned by producer, can producer get agreement
for land on which to apply waste?
Soil Investigation
Is soil suitable for lagoon? . -Z—
Is a clay liner required?
If yes, is clay available on site?
Questionable
Is a core trench required?
Test holes will be dug initially in the general area of proposed lagoon._ X dieing desigi-
osition of the Lagoon is c d to an area where no test holes were gevLou& dug- additional
test holes MgLL be rMked.
Comments
This site investigation is valid as long as the design and construction of lagoon continues
in a reasonable time period. Undue delays or hesitancy in construction may require that site
be re -evaluated -
Evaluator ,W
(WF Engineering)
Signature
(Producer)
Date �a S
Date

=34 55• SWA SEVEN SPRINGS 15• QUADRANGLE
�y
i 35 136 2 330 000 FEET 7 �3
= Cem 77°,,,52'30"
- 35°07'30"
1 r
Cem
500000
FEET
Ile
el
Cem_ L 1�
p�� • 1 / j :_ 'Cem i �X 3689
u Ouf1¢ g `
e 1 ports u� y sso
Cem0 -� ~ cm -
if _Try Cem Cem
\tea S2i- •d\ I6,5 -_ _ --__-� a `\� - - • ` / ' _ -�
it
Cems
'� �..- V 1 PL E s q ice. • � -` to % ,r �� 3e8
I
940
�• ram,• I �1.�`- j _- � ��71
1509 / / mutts •.Su ,- ,�
:Store
/ ' \ 3e81
a� _moo$" `_ �' -- - / \. CONVERSION
SCAM
LES
lilp
Feet Meters
Cem
4500
I° � �14000
7e86
151.
49
Ce
13000 4000
{ ci,l�`: / •� d' 12000
3500
Cern •er <'' N • u! � � 11000
385
`7: Cem
�',Q I i+ Cfi 1f r f, 9.;� „,- �. -e.k• v j 3000 -•_.J'-
9000

LAGOON SITE SOILS INVESTIGATION
PROJECT:. COUNTY:
FIELD INVESTIGATION BY: A-" DATE:
SITE SKETCH
/J4�'SEw
-
fiiLp
.
l
oNo
�
i
IL
BORING
DEPTH
SCALE
WT
-v-
' BORING NUMBER AND PROFILE
I •
/
TS/
C3cr�cc 5.�.✓.�
O - 3 •
,- % '
r
1At rrcw lon.�r�'i
3= y� .; t r3� lsw„ �rao
7 �- /�/ •
RJ?Y IAr Jbi�/Eo N
9 f , s two tLr,cco IA.+A'%o
i
f_
HO •N/ri •� i •
Z
BORING/ SAMPLING METHOD:i AeK�eE SIGNATURE:

Grower. Pleasant Grove Nursery #2 Designed By: JLD
Address: 221 Scott's Store Rd. Checked By: JNT
Mt. Olive, NC 28365 Date: 11 /13/96
Countv: Duc)lin Sheet 1 of 7
AN
FARM INFORMATION
Nursery:
Finishing:
ROBIC WASTE LAGOON DESIGN
Farrow'to weanling:
Farrow to feeder.
Farrow to finish:
Boars:
Storage Period:
25 Yr. / 24 Hr Storm Event
°Heavy Rain° Factor
Rainfall in Excess of Evaporation
Additional Water Usage:
Additional Drainage Area:
LAGOON INFORMATION
Farm Population:
-------------------
-------------------
-------------------
-------------------
-------------------
-------------------
-------------------
--------------------
Not Applicable
-------------------
-------------------
-------------------
Is Lagoon Designed as an Irregular Shape?
(Y/N) — — - — — — -- — —N
Does Operator Want Emergency Spillway?
(Y/N) — — — — — — -- — -=N
Is This Design for an Existing Farm?
(YIN) — — — — — — — — — Y
Is Drain Tile Req'd to Lower SHWT?
(Y/N) ;— — — — — — — — — N
Seasonal High Water Table Elev: -------------------
Freeboard: --------------------
Emergency Spillway Flow Depth: Not Applicable
Top of Storm / Spillway Buffer: Not Applicable
Side Slopes: --------------------
Inside Top Length: ---------------------
Inside Top Width: - --------------------
Top of Dike Elevation: — — — — —
— — — — — — — — — — — — — — -
Finished Bottom Elevation: -------------------
Start Pump Elevation: --------------------
Stop Pump Elevation:------------------
LAGOONVOLUME REQUIREDVOL
Storm Stor =
Temporary=
Permanent =
Total Volume =
15000 (Cu.Ft.)
33048 (Cu.Ft.)
78000 (Cu.Ft.)
126,048 (Cu.Ft.)
2600 Hd.
0
0
0
0
`T_'
180 Da
Days
rr
,Z
�
k '
c�
7.5 In.
X�
z�
7.0In.
"
C-C'
0
N
�.
0
99.80 Ft.
1.0 Ft
3 :1 (H:V)
120.0 Ft
200.0 Ft
103.70 Ft
93.70 Ft.
101.90 Ft
100.10 Ft
DESIGN VOLUMES %.REQ'D.
17,226 (Cu.Ft.) 114.84%
34,374 (Cu.Ft) 104.01 %
81,594 (Cu.Ft.) 104.61%
Min. Required Liner Thickness -------------------
Lagoon Surface Area: (Inside TOD)---------------_------
Murphy Family Farms Engineering A0. Box 759, Rose Hill NC 284W
105.67%
1.5 Ft
24,000 S.F.
[phone]

Address: 221 Scott's Store Rd.
Mt. Olive, NC 28365
Countv: Du0in
Checked By: JNT
Date: 11 /13/96
Sheet 2 of 7
ACTUAL DESIGN VOLUME CALCULATIONS
LAGOON STAGE -AREA VOLUMES
Contour
Elevation (FT.)
Area S
93.70
8,400
94.00
8,763
95.00
10,021
96.00
11,350
97.00
12,752
98.00
14,226
99.00
15,771
100.00
17,389
101.00
19,078
10200
20,840
103.00
22,674
103.70
24,000
Incr. Vol. (Cu. FTC Cumul. Vol. (Cu. FT)
2,574
2,574
9,392
11,967
10,686
22,652
12,051
34,703
13,489
48,192
14,998
63,191
16,580
79,771
18,234
98,004
19;959
117,964
21,757
139,720
16;336
156,056
These volumes were calculated using -the vertical averaae end area method.
TOTAL REOD VOLUME:
126,048
CF
CUMULATIVE VOL
ZONE-VOL
105.671%
END PUMP = = = = >
100.10
FT
81,594 CIF TR'MT
81,594
104.61 %
START PUMP = = =
101.90
FT
115,968 CIF TEMP
34,374
104.01%
MAX STORAGE = = >
10270
FT
133193 CIF STORM
17,226
114.84%
Murphy Family Farms Englneerhq
P.O. Box 759, Rase Hill NC 28458
[phone]

Murphy Family Farms Engineering P.O. Box 759, Rose Hill NC 28458 [phone]

Address: 221 Scott's Store Rd. -
Mt Olive, NC 28365
County: Duplin
Temporary Storage Volume: (Cont.)
Checked By: JNT
Date: 11 /13/96
Sheet 4 of 7
Rainfall in Excess of Evaporation:
Vol.= (Lagoon Surface Area + Additional Drainage Area) * Rainfall / 12in./ft
Vol. = (24000 sq.ft + 0 sq.tL) * 7 in. /12 in./ft.
Total Required Volume for Rainfall in Excess of Evap. (cu.ft.)= 14,000
Storm Storage:
Vol. =(Lagoon Surf. Area + Addt'l Drainage Area) * 25Yr./24Hr. Storm(in) / 12in./ft.
Vol.= (24000 sq.ft + 0 sq.ft) * 7.5 in. /12 in./ft.
Total Required Volume for 25Yr.--24Hr. Storm Event (cu.ft)= 15,000
"Heavy Rain" Storage:,
Vol.=(Lagoon Surf. Area + Addt'l Drainage Area) * 'Heavy Rain° Factor (in) / 12in./ft.
Vol.= (24000 sq.ft . + 0 sq.ft.) * Q.0 in. /12 in./ft.
Total Required Volume for'Heavy Rain' (cuff) = 0
(for Extended Periods of Chronic Rainfall)
Additional Water Storage:.
No Additional Water Storage is Retuired
Total Required Storm Storage
(25 Yr. / 24 Hr. Storm + "Heavy RainI _
Total Required Temporary Storage
(Manure Prod. + Excess Fr. Water + Rainfall Excess) _
Total Required Permanent Storage
(Treatment + Sludge) _
15,000 (C U . FT)
33,048 (CU. FT)
78,000 (CU.FT)
TOTAL REQUIRED VOLUME = 126048 (CU.FT.)
Murphy Family Fanns Engineerng P.O. Box 759, Rose Hill NC 284W (910) 28g-21 it

[grower. Pleasant Urove Nursery
Address: 221 Scott's Store Rd.
Mt. Olive, NC 28365,
Checked By: JNT
Date: 11 /13/96
.Sheet 5 of 7
LAGOON DESIGN SUMMARY
Top of Dike Elevation --------------------
Emergency Spillway Crest Elevation --------------------
Top of 25 yr/24 hr Storm Storage -------------------
Top of "Heavy Rain" Storage --------------------
Start Pump Elevation --------------------
End Pump Elevation --------------------
Top of Sludge Storage - - - - - - - - - - - _----_
Seasonal High Watertable Elev. --------------------
Finished Bottom Elevation -------------------
Inside Top Length --------------------
Inside Top Width - - - - - - - - -----------
Side Slopes -------------------
Lagoon Surface Area -------------------
Min. Liner Thickness (if required) -- - -------------
Freeboard Depth -------------------
Temporary Storage Period --------------------
Zone Depths:
103.70 FT.
Not Applicable
102.70 FT.
Not Applicable
101.90 FT.
100.10 FT.
Not Applicable
99.80 FT.
93.70 FT.
120.00 FT.
200.00 FT.
3:1 H:V
24,000 SF
1.5 FT.
1.00 FT.
180 Days
TOTAL DESIGN VOLUME = 133193 (CU.FT.)
Treatment / Sludge Storage Zone Depth - - - - - - - - - - - 6.4 FT.
Temporary Storage Zone Depth - - - - - - - - - - - 1.8 FT.
Freeboard / Storm Storage Zone Depth - - - - - -- - - - -- _ 1.8 FT.
Total Lagoon Depth - - - - - - - - - - - - 10.0 FT.
Murphy Family Farms Engineerhg P.O. Box 759, Rose Hill NC 28458 [phone]

Grower: Pleasant Grove Nursery #2 Designed By: JLD
Address:' 221 Scott's Store Rd. Checked By: JNT
Mt. Olive, NC 28365 Date: .11/13/96
Countv: Duolin Sheet 6 of 7
ZONE ELEVATIONS
TOP OF DIKE ELEV = 103.70
1 1 1 1
/ 1 TOP OF STORM ELEV = 102.70 1 1
1 1 1 1
1 1
1 1
STRT PMP EL.= 101.90 TOP OF TEMP STORAGE ELEV = 101.90 /
END PIMP EL. = 100.10 1 TOP OF TREAT ELEV = 100.10 / SHWT = 99.80
1 1
1 1
1 1
FINISHED BOTTOM ELEV = 93.70
Murphy Family Farms
P.O, Box 759, Rose H111 NC 28458
[phone]

wrower, Peasant urove-Nursery 42 Uesignea Liy: JLL)
Address: 221 Scott's Store Rd. Checked By: JNT
Mt Olive, NC 28365 Date: 11/13/96
Countv: Dublin Sheet 7 of 7
This livestock waste treatment lagoon is designed in accordance with the North Carolina
Natural Resources Conservation Service PRACTICE STANDARD 359— WASTE TREATMENT
LAGOON, revised prior to June, 1996.
Emergency Spillway:
An Emergency Spillway is not required.
NOTE: See attached Waste t tif'iza0P iRkP4
�� rl
DESIGNED: AL65
DATE:
COMMENTS:
Murphy Family Farms Engineering P.O. Box 759, Rose HN NC 28458 (310) 289-211 r

ADDRESS: 221 Scott's Store Rd. CHECKED BY: JNT
Mt. Olive, NC 28365 DATE: 11/13/96
COUNTY: Duplin SHEET 1 OF 3
SPECIFICATIONS FOR CONSTRUCTION OF WASTE TREATMENT LAGOONS
FOUNDATION PREPARATION:
The foundation area of the lagoon embankment and building pad shall be cleared of
trees, logs, stumps, roots, brush, boulders, sod, and rubbish. Satisfactory disposition
will be made of all debris. The topsoil from the lagoon and pad area should be stripped
and stockpiled for use on the dike and pad areas. After stripping, the foundation area
of the lagoon embankment and building pad shall be thoroughly loosened prior to placing
the first lift of fill material to get a good bond.
EXCAVATION AND EARTHFILL PLACEMENT
The completed excavation and earthfill shall conform to the fines, grades, and elevations
shown on the plans. Earthfill material shall be free of material such as sod, roots, frozen
soil, stones over 6 inches in diameter, and other objectionable material.. To the extent they
are suitable, excavated material may be used as fill. The fill shall be brought up in
approximately horizontal layers not to exceed 9 inches in thickness when loose and prior
to compaction. Each layer will be compacted by complete coverage with the hauling and
spreading equipment or standard tamping roller or equivalent method. Compaction will
be considered adequate when fill material is observed to consolidate to the point that
settlement is not readily detectable. - NOTE THE SPECIAL REQUIREMENTS FOR
PLACEMENT OF LINERS IN THE LINER SECTION OF THIS SPECIFICATION.
The embankment of the lagoon shall be installed using the more impervious materials from
the required excavations. Construction of fill heights shall include 5 percent for settlement
Dikes over 15 feet in height with an impoundment capacity of 10 acre-feet or more fall
under the jurisdiction of the NC Dam Safety Law and require permitting by the NC Dept. of
Environment, Health and Natural Resources, Land Quality Section. The height is defined
as the difference in elevation from the constructed height to the downstream toe of the dike.
Precautions shall be taken during construction to prevent excessive erosion and
sedimentation.
LINER:
THE MINIMUM REQUIRED CLAY LINER THICKNESS SHALL BE 1.5 FT.
NOTE: LINERS (PARTIAL OR FULL) ARE REQUIRED WHEN INDICATED ON THE
DRAWINGS OR WHEN MATERIAL IS ENCOUNTERED DURING CONSTRUCTION THAT
WILL NOT PROVIDE THE PERMEABILITY LIMITS AS STATED LATER IN THIS SECTION.
SUCH MATERIAL IS CONSIDERED UNSUITABLE WITH RESPECT TO LINING. A TYPICAL
CROSS SECTION OF THE LINER IS INCLUDED IN THE DRAWINGS WHEN LINERS
ARE REQUIRED.
Murphy Family Farms Engineering AO. Box 759, Rose Hill NC 28456 (9 io)289-21 r r

ADDRESS: 221 Scott's Store Rd. CHECKED BY: JNT
Mt. Olive, NC 28365 DATE: 11/13/96
COUNTY: Duplin SHEET 2 OF 3
When areas of unsuitable material are encountered, they will be overexcavated below
finish grade to the specified depth as measured perpendicular to the finish grade. The
foundation shall be backfilled as specified to grade with a material approved by the
engineer or his representative.
REFER TO THE DRAWINGS FOR SPECIAL CONSIDERATIONS.
Soil liner material shall come from an approved borrow area The minimum moisture
content of the liner material shall be optimum moisture content which relates to that
moisture content when the soil is kneaded in the hand it will form a bail which does not
readily separate. Water shall be added to borrow as necessary to insure proper moisture
content during placement of the liner. The moisture content of the liner material shall not
be less than optimum moisture content during placement The maximum moisture
content relates to the soil material being too wet for efficient use of hauling equipment and
proper compaction. Proper compaction of the liner includes placement in 9 inch lifts and
compacted to at least 95 percent of the Standard Proctor Maximum Dry Density
(ASTM D698) of the liner material. When smooth or hard, -the previous lift shall be scared
and moistened as needed before placement of the next lift.
The single most important factor affecting the overall compacted permeability of a clay
liner, other than the type of clay used for the liner, is the efficient construction processing
of the compacted liner. The sequence of equipment irf an established pattern helps
assure uniformity in the entire placement and compaction process. For most clay soils, a
tamping or sheepsfoot roller is the preferred type of compaction equipment
In accordance with NRCS South National Technical Center (SNTC) Technical Note 716
(revised September 1993) the maximum allowable specific discharge of the liner is
1.0 x 10-3 cm/sec. This specific discharge is -dependant on the permeability of the
liner material, the liner thickness, and the hydrostatic pressure on the liner. With the
minimum required liner thickness stated earlier and the maximum liquid depth in the
lagoon, the maximum permeability of the compacted liner. is 1.25 x 10-6cm/sec. -Upon
completion of the liner, undisturbed samples will be taken and tested for actual
permeability. Any permeability tests indicating a higher permeability than stated above
will be considered as failing. Failing tests will require recompaction of the liner material
and retesting.
For lagoons being built in soils which do not require clay lining the same permeability
requirements apply as for clay liners and testing of the in —situ material will be conducted.
During the excavation process, soils at the excavated surface are loosened as adjacent
material is being removed. As a result, the permeability of these surface soils.is increased.
To insure proper compaction and minimum soil permeability; when lagoon excavation is
complete the inner side slopes and bottom shall be roiled thoroughly prior to testing.
Murphy Famr7y Farms Engineering P.O. Box759, Rose Hill NC 28458 [phone]

GROWER: Pleasant Grove Nursery
ADDRESS: 221 Scott's Store Rd.
Mt. Olive, NC 28365
CHECKED BY: JNT
DATE: 11 /13/96
3
The soil liner shall be protected from scour produced by the discharge from waste outlet
pipes. This can be done by using some type of energy dissipator: concrete flumes,
concrete blocks laid tightly together, or using flexible pipe outlets on waste pipes.
Alternatives to soil liners are synthetic liners and bentonhe sealant. When these are
specified, additional construction specifications are included with this Construction
Specification or are shown on the drawings.
CUTOFF TRENCH:
A cutoff trench shall be constructed under the embankment area when called for in the
notes on the drawings or as shown on a typical cross section on the drawings. The final
dimensions of the cutoff trench shall be determined by observation of the foundation
materials during construction.
VEGETATION:
All exposed embankment and other bare constructed areas shall be seeded to the
planned type of vegetation as soon as possible after construction according to the
seeding specifications. Topsoil, if available on site should be placed on areas of the dike
and pad to be seeded. Temporary seeding or mulch shall be used if recommended
permanent vegetation is out of season dates for seeding. Permanent vegetation should
be established as soon as possible during the next period of approved seeding dates.
REMOVAL OF EXISTING TILE DRAINS:
An observation trench shall be dug along the perimeter of the lagoon 25 feet outside the
proposed embankment toe to verify that no subsurface drain file lines are present in the
lagoon area The trench shall be dug to a minimum depth of five feet and shall have a width
adequate to accommodate equipment used for backfill and compaction. Trench side
slopes shall be 1:1 or flatter. Trench backfill shall be compacted as stated in the
EXCAVATION AND EARTHFILL PLACEMENT section of the specification.
When tile drains are encountered, the tile will be removed to a minimum of 25 feet beyond
the outside toe of slope of the dike. The tile trench shall be backfilled and compacted with
material approved by the engineer or his representative. Tile drains that are removed
shall be either capped off or rerouted around. the lagoon, as directed by the engineer or
his representative.
SAFETY AND HEALTH REQUIREMENTS:
All operations shall be carried out in a safe, skillful, and workmanlike manner. All safety and
health regulations shall be observed and appropriate personal safety and health measures
used at all times during construction.
Murphy Family Farms Engineering P.O. Box 759, Rose Hill NC 28458 [phone]

GHUWEH: Pleasant Grove Nursery #2 DESIUNED BY: JLD
ADDRESS: 221 Scotts Store Rd. CHECKED BY: JNT
Mt Olive, NC 28365 DATE: 11 /13/96
COUNTY: Duolin SHEET 1 OF 1
SEEDING SPECIFICATIONS
ACREAGE TO BE SEEDED: 2.0 ACRES
USE THE SEED MIXTURE INDICATED AS FOLLOWS:
120 LBS. FESCUE GRASS AT 60 LBS./ACRE
(BEST SUITED ON CLAYEY OR WET SOIL CONDITIONS)
SEEDING DATES: SEPTEMBER 1 TO NOVEMBER 30
FEBRUARY 1 TO MARCH 30
60 LBS. RYE GRAIN AT 30 LBS./ACRE (NURSERY FOR FESCUE)
120 LBS. 'PENSACOLA' BAHIA GRASS AT 60 LBS./ACRE
(SEE FOOTNOTE NUMBER 1) '
SEEDING DATES: ' MARCH 15 TO JUNE 15
16- LBS. HULLED COMMON BERMUDA GRASS AT 8 LBS./ACRE
(SUITED FOR MOST SOIL CONDITIONS)
SEEDING DATES: APRIL 1 TO JULY 31
20 LBS. UNHULLED COMMON BERMUDA GRASS AT 10 LBS./ACRE
SEEDING DATES: JANUARY 1 TO MARCH 30
80 LBS. RYE GRASS AT 40 LBS,/ACRE (TEMPORARY VEGETATION)
SEEDING DATES: DECEMBER 1 TO MARCH 30
APPLY THE FOLLOWING,
2000 LBS. OF 10-10-10 FERTILIZER (1000 LBS./ACRE)
4 TONS OF DOLOMITIC LIME (2 TONS/ACRE)
200 BALES OF SMALL GRAIN STRAW (100 BALES/ACRE)
ALL SURFACE DRAINS SHOULD BE INSTALLED PRIOR TO SEEDING. SHAPE ALL
DISTURBED AREAS IMMEDIATELY AFTER EARTH MOVING IS COMPLETED.
APPLY LIME AND FERTILIZER THEN DISK TO PREPARE A 3 TO 4 INCH SMOOTH
SEEDBED. - APPLY SEED ANDFIRM SEEDBED WITH A CULTIPACKER OR SIMILAR
DEVICE. APPLY MUCH AND SECURE WITH AN ANCHORING TOOL OR NETTING.
1. PENSACOLA BAHIA GRASS IS SLOWER TO ESTABLISH THAN COMMON
BERMUDA GRASS. WHEN USING BAHIA, IT 1S RECOMMENDED THAT 8
LBS./ACRE OF COMMON BERMUDA BE INCLUDED TO PROVIDE COVER UNTIL
BAHIA GRASS IS ESTBLISHED. '
Murphy Family Farms Engineerbrg P.O. Box759, Rose ill NC 28458 [phone]

lA1 &V if VI 1. 1 IVGIw7W 1l VI VY4 1\MI JLly 7T 94 _�yV-1 ��_ v . . -1.
ADDRESS: 221 Scott's Store Rd. CHECKED BY: JNT
Mt. Olive, NC 28365 DATE: 11/13/96
COUNTY: Duolin SHEET 1 OF 2
OPERATION AND MAINTENANCE PLAN
This lagoon is designed for waste treatment (permanent storage) and 180 days of
temporary storage. The time required for the planned fluid level (permanent and
temporary storage) to be reached may vary due to site conditions, weather, flushing
operations, and the amount of fresh water added to the system.
The designed temporary storage consists of 180 days of temporary storage for:
(1) manure production of animals, (2) excess fresh water storage, (3) rainfall in
excess of evaporation, (4) storage for the 25 year / 24 hour storm for the location,
(5) and, if applicable, an additional "heavy rain" storage volume for chronic rainfall
events. Allocation for any additional fresh water usage is also included in the
temporary storage. The volume of waste generated from a given number of animals
will be fairly constant throughout the year; but excess rainfall will vary from year to year.
The 25 year rainfall will not be a factor to consider in an annual pumping cycle, but
this storage volume must always be available.
A staff gauge must be installed in the lagoon that indicates the start pumping and stop
pumping levels. The start pumping level is the maxium liquid level under normal operating
conditions. The stop pumping level is the minimum liquid level under normal
operation to maintain required treatment volume and depth. Pumping can be started
and stopped anywhere between these two elevations for operating convenience as site
conditions permit, such as weather, soils, crop; and equipment in order to apply waste
without runoff or leaching. However, it is recommended that the lagoon be kept
pumped down as much as possible.
Land application of wastewater is recognized as an acceptable method of disposal.
Methods of application include solid set, center pivot, guns, and traveling guns. Care
should be taken when applying waste to prevent damage to crops.
The following items are to be carried out:
1. It is required that the treatment lagoon be precharged to one --half the treatent volume
or as otherwise specified on the lagoon design drawings before wastes are introduced.
The purpose is to prevent excessive odors during start-up. Precharging reduces the
concentration of the initial waste entering the lagoon thereby reducing odors. Solids should
be covered with effluent at all times. When precharging is complete, flush buildings with
recycled lagoon liquid. Fresh water should not be used for flushing after initial filling.
2. The attached Waste Utilization Plan shall be followed. The plan recommends
sampling and testing of waste before land application.
Murphy Family Farms Engineering P. 0 Box 759, Rose Hill NC 28458 (9 fa) 289-2111

ADDRESS: 221 Scott's Store Rd.
Mt. Olive, NC 28365
CHECKED BY-' JNT
DATE: 11 /13/96
SHEET 2 OF 2
3. Begin temporary storage pump —out of the lagoon when the fluid level reaches the
elevation 101.90 as marked by the staff gauge. Stop pump —out when the fluid level
reaches elevation 100.10. This temporary storage, less 25 year / 24 hour storm,
contains 34374 cubic feet or 257114 gallons.
4. The recommended maximum amount to apply per irrigation is one (1) inch and the
recommended maximum application rate is 0.3 inches per hour. Refer to the waste
utilization plan for further details.
5. Keep vegetation on the embankment and areas adjacent to the lagoon mowed
annually. Vegetation should be fertilized as needed to maintain a vigorous stand.
6. Repair any eroded or damaged areas and establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stdble outlets.
4
8. Keep a minimum of 25 feet of grass vegetated buffer around waste utilization
fields adjacent to perennial streams. Waste will not be applied -in open ditches.
Do not pump within 200 feet of a residence or within 100 feet of a well. Waste shall
be applied in a manner such that waste will not reach other property and public
rights —of —way.
9. The Clean Water Act of 1977 prohibits the discharge of pollutants into waters
of the United States. Waste shall not be discharged into surface waters, drainageways,
or wetlands by either discharge or by over —spraying. The Department of Environment,
Health, and Natural Resources, Division of Environmental Management,
has the responsibility for enforcing this law.
Murphy Family Farms Engineering p 0. sox 759, Rose Hill NC 28458 (910) 289--21 i 1

DEiU-Jf--QEM-WQ
q�;� 44TS & ENGIN, UNIT}.
97 APR 16 WO: : -25"
Insect Control Checklist for Animal Operations
Source Cause BMPs to Control Insects Site Specific Practices
Flush Gutters • Accumulation of solids ❑ Flush system is designed and operated
sufficiently to remove accumulated solids from
gutters as designed.
❑ Remove bridging of accumulated solids at
discharge
Lagoons and Pits • Crusted Solids Maintain lagoons, settling basins and pits where
pest breeding is apparent to minimize the
crusting of solids to a depth of no more than 6 -
8 inches over more than 30% of surface.
Excessive Vegetative • Decaying vegetation Maintain vegetative control along banks of
Growth lagoons and other impoundments to prevent
accumulation ofdecaying vegetative matter
along waters edge on impoundment's perimeter.
Feeders • Feed Spillage Design, operate and maintain feed systems (e.g.,
bunkers and troughs) to minimize the
accumulation of decaying wastage.
I Clean up spillage on a routine basis (e.g., 7 - 10
day interval during summer; I5-30 day interval
during winter).
Storage
residues Pf Reduce moisture accumulation within and
around immediate perimeter of feed storage
areas by insuring drainage away from site
and/or providing adequate containment (e.g.,
covered bin for brewers grain and similar high
moisture grain products).
❑ Inspect for and remove or break up accumulated
solids in filter strips around feed storage as
needed.
AMIC - November I I, 1996, Page I

Source Cause BMPs to Control Insects. Site Specific Practices
Animal Holding Areas Accumulations of animal wastes O Eliminate low areas that trap moisture along
and feed wastage fences and other locations where waste
accumulates and disturbance by animals is
minimal.
O Maintain fence rows and filter strips around
animal holding areas to minimize
accumulations of wastes (i.e., inspect for and
remove or break up accumulated solids as
needed).
Dry Manure Handling • Accumulations of animal wastes O Remove spillage on a routine basis (e.g., T- 10
Systems day interval during summer; 15-30 day interval
during winter) where manure is loaded for land
application or disposal.
O Provide for adequate drainage around manure
stockpiles.
0 Inspect for and remove or break up accumulated
wastes in filter strips around stockpiles and
manure handling areas as needed.
For more information contact the Cooperative Extension Service, Department of Entomology, Box 7613, North Carolina State University,
Raleigh, NC, 27695-76f3.
AMIC -November 11, 1996, Page 2

GROWER: Pleasant Grove Nursery #2 DESIGNED BY: JLD
ADDRESS: 221 Scott's Store Rd. CHECKED BY: JNT
Mt Olive, NC 28365 DATE: 11/13/96
COUNTY: Duglin SHEET 1 OF 2
Emergency Action Plan
Using this outline as guidance, you should develop a specific emergency action plan for your
waste handling system.. This plan will be implemented in the event that wastes from your
operation are leaking, overflowing, or running off the site. You should NOT wait until wastes
reach surface water or leave your property to consider that you have a problem. You should
make every effort to ensure that this does not happen. This plan should be available to all
employees at the facility, as accidents, leaks, and breaks could happen at any time. Your
plan should follow this format:
1. Stop the release of wastes. Depending on the situation, this may or may not be
possible. Suggested responses to problems are listed below: _
A. Lagoon overflow —passible solutions are:
add soil to berm to temporarily increase elevation of dam —any permanent
alteration of the dam should be approved by a qualified professional engineer
or qualified technical specialist "
pump wastes to field at an acceptable late
stop all additional flow to the lagoon (waters) --hold waste in house if possible
call a pumping contractor
make sure no surface water is entering_ lagoon
NOTE: The above listed activities should be started when your lagoon level has exceeded
the temporary storage level.
B. Runoff from waste application field —actions include:
immediately stop waste application
create a temporary diversion or berm to contain the waste -on the field
incorporate waste to reduce further runoff
C. Leakage from the waste distribution system:
pipes and sprinklers —actions include:
— stop recycle (flushing system) pump
— stop irrigation pump
— close valves to eliminate further discharge
— separate pipes to create an air gap and stop flow
flush system, houses, solids separators —actions include:
stop recycle (flushing system) pump
stop irrigation pump
make sure no siphon effect has been created
separate pipes to create an air gap and stop flow
D. Leakage from base or sidewall- of lagoon. Often these are seepage as opposed to
flowing leaks —possible action*:
dig a small well or ditch to catch all seepage,put in a submersible
pump, and pump back into lagoon
if holes are caused by burrowing animals,'trap or remove animals and
fill holes and compact with a clayey soil
other holes may be likewise temporarily plugged with clay soil
Murphy Family Farms Engineenang P.D. Box 759, Rose Hill NC 28458 [phone]
3
4

GHOWER: Pleasant Grove Nursery #2 Ut51UNEU BY: JLD
ADDRESS: 221 Scotfs Store Rd. CHECKED BY: JNT
Mt. Olive, NC 28365 DATE: 11/13/96
COUNTY: Du lin SHEET 2 OF 2
*Lagoon problems require the consultation of an individual experienced in the
design and construction of lagoons for permanent repair measures.
2. Assess the extent of the spill and note any obvious damages.
A. Did the waste reach any surface water?
B. Approximately how much was released and for what duration?
C. Any damage noted, such as employee injury, fish kills, or property damage?
3. Contact appropriate agencies.
B. During noral business hours, call your DE regional office, at 910--395-3900
after hours, emergency number. 910-733-3942. Your phone call should
include: your name, facility, telephone number, the details of incident from
item 2 above, the exact location of the facility, and the location or direction
of movement of the spill, weather and wind conditions, what corrective
measures have been under taken, and the seriousness of the situation.
C. If spill leaves, or is likely to leave, property or enters surface waters, call
local emergency management service (EMS)at 910-296-2160.
D. Instruct EMS to contact local Health Department.
E. Contact local Soil and Water Conservation District Natural Resources Conservation
Service office at 910-296-2121 for advice/technical assistance.
910-296-2143 for advice/technical assistance.
A. Contact Murphy family Farms Land and Nutrient Manageent Departent at 910-
289-2111 for advice/technical assistance.
4. Implement procedures as advised by DEM and technical assistance agencies to rectify
the damage, repair the system, and reassess the waste management plan to keep
problems with release of wastes from happening again.
DUPLIN COUNTY COOPERATIVE EXTENSION SERVICE
PO BOX 458, KENANSVILLE, NC 28349
910-296-2143
DUPLIN COUNTY SOIL AND WATER CONSERVATION DISTRICT
NATURAL RESOURCES CONSERVATION SERVICE
PO BOX 277, KENANASVILLE, NC 28349
910-296-2121
DUPLIN COUNTY EMERGENCY MANAGEMENT SYSTEM
PO BOX 909, KENANASVILLE, NC 28349
910— 296— 2160
DIVISION OF ENVIRONMENTAL MANAGEMENT
127 CARDINAL DRIVE EXT
WILMINGTON, NC 28405 — 3845
910-395--3900
Murphy Family Farts Engineering P.O. Box 759, Rose Hill NC 28456 [phone]

Swine Farm Waste Management Odor Control Checklist
Source Cause BMPs to MInimize Odor Site Specific Practices
Farmstead • SW
Vegetative or wooded buffers;
O Recommended best management practices;
XGood judgment and common sense
Animal body surfaces • Dirty manure -covered animals Dry floors
Floor surfaces • Wet manure -covered floors Slotted floors;
l�l Waterers located over slotted floors;
Feeders at high end of solid floors;
O Scrape manure buildup from floors;
O Underfloor ventilation for drying
Manure collection pits • Urine; 0 Frequent manure removal by flush, pit recharge,
• Partial microbial decomposition or scrape;
O Underfloor ventilation
entilation exhaust fans • Volatile gases; 0 Fan maintenance;
Dust 0 Efficient air movement
Indoor surfaces • Dust X Washdown between groups of animals;
13 Feed additives;
C3 Feeder covers;
Feed delivery downspout extenders to feeder
covers
Flush tanks • Agitation of recycled lagoon
.0 Flush tank covers;
liquid while tanks are filling
0 Extend fill lines to near bottom of tanks with
anti -siphon vents
Flush alleys • Agitation during wastewater
0 Underfloor flush with underfloor ventilation
conveyance
Pit recharge points • Agitation of recycled lagoon
Extend recharge lines to near bottom of pits
liquid while pits are filling
with anti -siphon vents
Lift stations • Agitation during sump tank
17 Sump tank Lovers
filling and drawdown
Outside, drain collection Agitation during wastewater 0 Box covers
orjunction boxes conveyance
AMOC -November 11, 1996, Page 3

Source Cause BMPs to Minimize Odor Site Specific Practices
End of drainpipes at • Agitation during wastewater Extend discharge point of pipes underneath
lagoon conveyance lagoon liquid level
• votame gas emisst
• Biological mixing;
• Agitation
Proper lagoon liquid capacity;
Correct lagoon startup procedures;
❑ Minimum surface area -to -volume ratio;
0 Minimum agitation when,pumping;
❑ Mechanical aeration,
❑ Proven biological additives
Irrigation sprinkler' • High pressure agitation; P Irrigate on dry days with little or no wind;
nozzles . Wind drift 0 Minimum recommended operating pressure;
t Pump intake near Iagoon liquid surface;
❑ Pump from second -stage lagoon
Storage tank or basin • Partial microbial decomposition; ❑ Bottom or midlevel loading;
surface . Mixing while filling; ❑ Tank covers;
• Agitation when emptying p Basin surface mats of solids;
0
Proven biological additives or oxidants
Settling basin surface
• Partial microbial decomposition;
17
Extend drainpipe outlets underneath liquid
• Mixing while filling;
level;
• Agitation when emptying
❑
Remove settled solids regularly
Manure, slung or sludge
• Agitation when spreading;
❑
Soil injection of slung/sludges;
spreader outlets
• Volatile gas emissions
0
Wash residual manure from spreader after use;
❑
Proven biological additives or oxidants
Uncovered manure,
• Volatile gas emissions while
C]
Soil injection of slurry/sludges
slurry or sludge on field
drying
CI
Soil incorporation within 48 hrs.;
surfaces
O
Spread in thin uniform layers for rapid drying;
O
Proven biological additives or oxidants
Dead animals
• Carcass decomposition
Proper disposition of carcasses
Dead animal disposal
• Carcass decomposition
❑
Complete Covering of carcasses in burial pits;
pits
❑
Proper location/construction ot'disposal pits
Incinerators
; • Incomplete combustion
❑
Secondary stack burners
AMOC -November 11, 1996, Page 4

Source Cause BMPs to Minimize Odor Site Specific Practices
Standing water around • Improper drainage; )27 Grade and landscape such that water drains
facilities . Microbial decomposition of away from facilities
organic matter
Manure tracked onto • Poorly maintained access roads Farm access road maintenance
public roads from farm
access
Additional Information :
Available From
Swine Manure Management ; 0200 Rule/BMP Packet
NCSU, County Extension Center
' Swine Production Farm Potential Odor Sources and Remedies ; EBAE Fact Sheet
NCSU - BAE
Swine Production Facility Manure Management: Pit Recharge - Lagoon Treatment; EBAE 128-88
NCSU - BAE
Swine Production Facility Manure Management: Underfloor Flush - Lagoon Treatment; EBAE 129-88
NCSU-BAE
Lagoon Design and Management for Livestock Manure Treatment and Storage; EBAE 103-83
NCSU - BAE
Calibration of Manure and Wastewater Application Equipment; EBAE Fact Sheet
NCSU-BAE
Controlling Odors from Swine Buildings; PIH-33
NCSU - Swine Extension
Environmental Assurance Program ; NPPC Manual
NC Pork Producers Assoc
Options for Managing Odor; a report from the Swine Odor Task Force
NCSU Agri Communications
Nuisance Concerns in Animal Manure Management: Odors and Flies; PRO107, 1995 Conference Proceedings
Florida Cooperative Extension
AMOC - November 11, 1996, Page 5

Mortality Management Methods
(check which method(s) are being implemented)
❑ Burial three feet beneath the surface of the ground within 24 hours after
knowledge of the death. The burial must be at least 300 feet from any flowing
stream or public body of water.
Rendering at a rendering plant licensed under G.S. 106-168.7
'Dc�Ml> Fin A4,- Fwj-1 Fcqz. VeAv gAji"ri r tau.Er-ncsAJ 81 Tr%uc
❑ Complete incineration
❑ In the case of dead poultry only, placing in a disposal pit of a size and design
approved by the Department of Agriculture
❑ Any method which in the professional opinion of the State Veterinarian would
make possible the salvage of part of a dead animal's value without endangering
human or animal health. (Written approval of the State Veterinarian must be
attached)
rn
�
mm<
-r�
�Q
'
c3
CA
December 18, 1996

ANIMAL WASTE UTILIZATION PLAN
Producer: ROBERT KORNECAY
Location: 221 SCOTTS STORE ROAD
MOUNT OLIVE NC 28365
Telephone: [phone]
Type Operation: Existing Wean to Feeder Swine
Number of Animals: 5200.00 pigs ►
-r
; ?
(Design Capacity)
~ ��
STORAGE STRUCTURE: Anaerobic Waste Treatment Lagoon
APPLICATION METHOD: Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent
a
pollution of surface water and/or groundwater. The plant nutrients in the animal waste
-�
should be used to reduce the amount of commercial fertilizer required_ for the crops in the
fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. 'Waste should be
analyzed before each application cycle. Annual soil tests are strongly encouraged so
that all plant nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to
maximize the fertilizer value of the waste and to ensure that it is applied in an
environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the
nutrient content of the waste. Do not apply more nitrogen than the crop
can utilize.
2. Soil types are important as they have different infiltration rates, leaching
potentials, cation exchange capacities, and available water holding
capacities.
3. Normally waste shall be applied to land eroding at less than b tons per acre
per year. Waste may be applied to land eroding at 5 or more tons per acre
annually, but less than 10 tons per acre per year providing that adequate
filter strips are established.
4_ Do not apply waste on saturated soils, when it is raining, or when the
surface is frozen. Either of these conditions may result in runoff to surface
waters which is not allowed under DEM regulations.
5. Wind conditions should also be considered to avoid drift and downwind -90Qr
problems.
Page: 1

041/07/97 13:09 %Y9102962122 USDA FRCS Q 002
ANIMAL WASTE UTILIZATION PLAN
6. To maximize the value of the nutrients for crop production and to reduce the
potential for pollution, the waste should be applied to a growing crop or
epplied r,ut_ HIME Lhuii 30 clays prlur to planting a crop or forages breaking
dormancy. Injecting the waste or disking will conserve nutrients and reduce
odor problems.
This plan is based on the waste application method shown above. if you choose to
change methods in the future, you need to revise this plan. Nutrient levels for different
application methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient
content for this type of facility. Acreage requirements should be based on the waste
analysis report and volume of waste from your waste management facility. In some
cases you may want to have plant analysis made, which could allow additional waste to
be applied. Provisions shall be made for the area receiving waste to be flexible so as to
accommodate changing waste analysis content and crop .type. Lime must be applied to
maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with
15A NCAC 2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
5200 pigs x .40 tons waste/pigs/year = 2080 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
5200 pigs x .48 lbs PAN/pigs/year = 2496-lbs. PAN/year
Applying the above amount of waste is a big job. You should plan time and have
appropriate equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on the crop to be
grown, soil type and surface application.

04/07/97 13:10 %T9102962122 USDA NRCS'
to w
i - ANIMAL WASTE UTILIZATION PLAN
TABLE 1: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & C SS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
----
or
----------
APPLY
RESID.
APPLIC
METH
N
TIME
3226
I
AUB
C
75
73. 55
2p
6
442.5
I
MAR-JUN
3226"1 I AUS I T 990 _[FEB-MAR
3226 1 1 AUB DSB 11.8 172 1 6 14:12
I JUN- S EK
15
END
i
TOTAL11414.5
- Indicates that this field is being overseeded (i.e. interplanted) or winter annuals
follow summer annuals.
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N
requirements. In the future, regulations may require farmers in some parts of
North Carolina to have a rnrtrient management plan that addresses all nutrients.
This plan only addresses nitrogen.

04/07/97 13:11 '$9102962122 USDA NRCS 0 004
ANIMAL WASTE UTILIZATION FLAN
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
- --- . _ - - --. - -,y- -- - ---Se---Sed required-specificati.an--
TRACT
FIELD
SOIL TYPE.& CLASS-
CROP
YIELD
LBS
COMM N
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
-------
APPLY
RESID.
APPLIC
2
METH
N
TIME
4092
AUB
C
75
73.75
20
14
1032.5
MAR-JUN
4092
1-2 -
JAUB
4092
2
AUB
4092
3
JAUB
409.2
'" 3
AUB
4092
15
3
AUB
4092
4
JAUB
4092
"4
AUB
4092
15
4
JAUB
W 145 j90
DSB 118-172
C 75 173.75 120
W 145 190
it
14
11260
FEE MAR
14
11008
JUN-SEPT
243.375
3.3
MAR-JUN
3.3
1-297
FEB-MAR
237.6
3.3
JUN-SEPT
C 75 173.75 120 110.4_1767'MAR-JUN
W 45 90 10.4 936
FEB-MAR
DSB 118 72 1 10.4 748.8
JUN-SEPT
I END !
TOTAL 6530.27
Indicates that this field is being overseeded (i.e. interplanted) or winter annuals follow
summer annuals.

'-04/07/97- --13-:-1-1----$9102a62122 USDA--NRCS
• ,a
ANIMAL WASTE UTILIZATION PLAN
Acreage figures may exceed total acreage in fields due to overseeding.
Ibs AW N (animal waste nitrogen) equals total required nitrogen less any
commercial nitrogen (COMM N) supplied.

04/07/97--10 :12 ... $9102962122 ITSDA . MRCS--- 1A006
. ANIMAL WASTE UTILIZATION PLAN
The following legend explains the crop codes used in tables 9 and 2 above:
CROP CODI
,..., _ _ _-. ... CROP_ '
UNITS -._
PER UNIT...
C
CORN
BUSHELS
1.25
DSB
DOUBLE CROPPED SOYBEANS
BUSHELS
4
W
WHEAT
BUSHELS
2
TABLE 1
TABLE 2
TOTAL
*-A
TOTALS FROM TABLES 1 AND 2
WETTABLE
LBS AW N USED
_ACRES
12
1414.5
-55.4
. 6530.275
BALANCE
-5448.775
*** This number must be less than or equal to 0 in -order to
fully utilize the animal waste N produced.
4 This number must be less than or equal to 0 in order to fully -utilize the animal
waste N produced.
Acres shown in each of the preceding tables are considered to be the usable acres
excluding -required buffers, filter strips along ditches odd --areas unable to receive waste,
and perimeter areas not receiving full application rates due to equipment limitations.
Actual total acres in the fields listed may, and most likely will be, more than the acres
shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
SLUDGE APPLICATION_
The waste utilization plan.must contain provisions for periodic land
application of sludge at agronomic rates_ The sludge will be nutrient
rich and will require precautionary measures to prevent over application
of nutrients or other elements. Your production facility will produce
approximately 395.2 pounds of plant available nitrogen per year in the
sludge.

- 04/07/97- - -- 13 :12 - $9102962122 - -- --- USDA NRCS
jL
ANIMAL WASTE UTILIZATION PLAN
If you remove the sludge every 5 years, you will have approximately 1976
pounds of PAN to utilize. Assuming you apply this PAN to hybrid
bermudagrass hayland at the rate of 300 pounds of nitrogen per acre, you
will need._6,,5.8666666667 acres„ of land._ If __you. apply _the sludgeto_ corn _a-t
the -rate.-of --12 5 -pounds of 'nitrogen -per- acre ,. - you-- will= .need 15.8a8 =-acres
of land. Please be aware that these are only estimates of the PAN and
land .needed. Actual requirements could vary by 25% depending on your
sludge waste analysis, soil types, realistic yields, and application
methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed - the intake rate of the -
soil at the time of irrigation sueh.that runoff or ponding occurs. This
rate is limited by initial soil moisture content, soil striicture, soil
texture, water droplet size, and organic solids. The application amount
should not exceed the available water holding capacity of the sail at the
time of irrigation nor should_the_plant available nitrogen app1.1ed__,exc.eed__
the ^nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan,
it is the responsibility of the producer and irrigation' designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables 1 and 2. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
The following tablo is providod as a guide for actabliching application
rates and amounts.
Tract
Field
Soil Type
-_.._
Crop
Application Rate
(in/hr)
Applic. Amount -
(inches)
3226
ATJB
C
.5
* 1
3226
2
AUB
DSB
.5
3226
y Z
AUB. _ -_.. _
W
.5
4092
2
AUB
C
.5
*1
4092
2
AUB
DSB ^
.5
*1
4092
3
AUB
C
.5
*1
4092
3
AUB
DSB
.5
*1
4092
4
AUB
C
.5
*1

04/07i97 � 13. 13 ---$91029$2122 LiSDA NRCS - 008
- - ANIMAL WASTE UTILIZATION PLAN
Et,
I
1'4092
4
AUB
4092
"2
:. AUK
4092
-3
AUB
4092
-4
AUB
DSB
.5
W
.5
W
.5
*1
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the Crop is not over
applied. In many situations, the application amount shown cannot
be applied because of the -nitrogen limitation:--The-maximum -
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180.00 days of temporary_ storage and the temporary
storage must be- removed on the average of once every 6.00 months. In no instance
should the volume of the waste be stored in your structure be within the 25 year 24
hour storm storage or one foot of freeboard except in the event of the 25 year 24 hour
storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader
equipment is operated properly to apply the correct rates to the acres shown in Tables 1
and 2. Failure to apply the recommended rates and amounts of nitrogen shown in the
tables may make this plan invalid.
Call your technical. specialist- after you receive the waste analysis -report for assistance in
determining the amount of waste per acre and the proper application rate prior to
applying the waste. I-
NARRATIVE OF OPERATION

04_/07/97 --__ $9102962122 _ USDA NRCS_- Q009
. ' ANIMAL WASTE UTILIZATION PLAN

-__--_� 04/1)7/0 1.3:14_ . M102962122 i1SnA MRCS E�101.A.-
y
WASTE UTILIZATION PLAN
RE-QU1RED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff, drift,
manmade conveyances, direct application, or direct discharge during operation or
land application. Any discharge of waste which reaches surface water is
prohibited. ,
2. There rust be documentation in- the design folder that the producer either owns
or has an agreement for use of adequate land on which to properly apply the
waste. If the producer does not own adequate land to properly dispose of waste,
he/she shall provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for waste application.
It is the responsibility of the owner of the facility to secure an update of the
Waste Utilization Plan when there is a change in the operation, increase in the
number of animals, method of utilization, or available land. .
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs _for
realistic crop yields based on soil- type, available moisture, historical data, for
conditions, and level of management, unless there are regulations that restrict the
rate of application for other nutrients.
4. Animal waste. -shall be applied to land eroding less than 5 tons per acre per year.
Waste may be applied to land that is eroding at 5 or more tons, but less than 10
- -Inns per­ar..re per- year providing -grass -filter strips-areinstalldd""hard-runoff lc vcs
the field. (See FOTG Standard- 393 -Filter Strip)
5. Odors can be reduced by injecting the waste or disking after waste application.
Waste should not be applied when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil
incorporated on conventionally tilled cropland. When applied to conservation
tilled crops or grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather and Climate in
North Carolina" for guidance.) .
7. Liquid waste shall be applied at rates not to exceed the sail infiltration rate such
that runoff does not occur offsite or to surface waters and in a method which
does not cause drift from the site during application. No ponding should occur in
order to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or
when the surface is frozen.
9. Animal waste shall -be applied on -actively growing crops in such a manner that the
crop is not covered with waste to a depth that would inhibit growth. The
potential for salt damage from animal waste should also be considered.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on
soils with a high potential for leaching. Waste nutrient loading rates on these
soils should be held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more than 30 days prior to
planting of the crop or forages breaking dormancy.

04/07/97 13:15 %Y9102962122 - USDA NRCS
. " WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
11. Any now swine facility sited on or after October 1, 1995 shall comply with the
following: The outer perimeter of the land area onto which waste is applied from
a lagoon that is a component of a swine farm shall be at least 50 feet from any
residential property boundary and from any perennial tibeern or rlvPr (other than__
an -irrigation ditch or. canal. -Animal waste other -than swine waste -from --facilities -
sited on- or after October 1, 1995), shall not be'applied closer than 25 feet to
perennial waters. (See Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to wells.,
13. Animal waste shall not be applied closer than 200 feet of dwellings other than
those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and public right-
of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or
wetlands by a discharge or by over -spraying. Animal waste may -be applied to
prior converted cropland provided they have been approved as a land application
site by a "technical specialist". Animal waste shall not be applied on grassed
waterways that discharges directly into water courses, and on other grassed
waterways, waste -shall- te applied at agfon6rhid-'rates in a manner that causes no
runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks,
etc., shall not be discharged into the animal waste management system.
17. A protective cover of appropriate vegetation will be established on all disturbed
areas (lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as
necessary, to protect the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc., are limited to areas where considered appropriate.
Lagoon areas should -be kept..mowed and accessible. Berms and structures
should be inspected regularly -for evidence of erosion, leakage or discharge.
18. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate
the possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a
regular basis to prevent breakdowns, leaks, and spills. A regular maintenance
checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops
for direct human consumption. However, if animal waste is used on crops for
direct human consumption it should only be 'applied preplant with no further
applications of animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and bottom elevations of
the temporary storage (pumping volume) of all waste treatment lagoons.
Pumping shall be managed to maintain the liquid level between the markers. A
marker will be required to mark the maximum storage vniiime for waste storage
ponds.

04/07/97--- 13:46---- $9102962122 - USDA 1rRCS- - - - �012
` WASTE UTILIZATION PLAN
REQUIRED SPI=CIROATIONS
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least
annually at crop sites where waste products are applied. Nitrogen shall be the
rate - determining element. Zinc and'copper levels in the soils shall be monitored
and alternative crop sites shall be used when these_ metals approach -excessive----- -
ievbls,.,,pH.=small-be adjusted- for -optimum crop- production_ and maintained.Soil=
and. waste analysis records -shall be kept for five years; Poultry dry waste
application records shall be maintained for three (3) 'years. Waste application
records for all other waste shall be maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina
regulations.

;04/07/97 13:16 -- $91029B2122- —USDA-NRGS .0013
i -
i ANIMAL WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Warne. of Farm%-
owner/Manager Agreement
I (we) understand and will follow and implement the specifications and the operation
and maintenance procedures established in the approved animal waste utilization plan
for the farm named above. I (we) know that any expansion to the existing design
capacity of the waste treatment and storage system or construction of new facilities
will require a new certification to be submitted to the North Carolina Division of
Environmental Management (NCDEM) before the new animals are stocked: I (we)
also understand that there must be no discharge of animal waste from this system to
surface wasters of the state from a storm- event less severe than the 25-year, 24-hour
storm. The approved plan will be filed on -site at the farm office and at the office of
the local Soil and Water Conservation District and will be available for -review by
NCDEM upon request.
Name of Facility Owner: ROBERT KORNEGAY
(Plea -so prinrJ
Signature. I Date: /7 /f"?
Name of Manager(If different from owner);
Signature: Date:
Name of person Preparing Plan. (Please pray.
Affiliation:DUPLIN SOIL AND WATZ -R .CONSERVATION DISTINCT
91 U-296-212a
Address (Agency): PO BOX 277
KENANSVILLE NC 28249
Signature. Date:
Phora No.

�,Il:�ial
IRRIGATION SYSTEM DESIGN PARAMETERS
Landowner/Operator Name: �-orl�r..q� �(rr f e /J'f1v County:
Address:
_ Date: 3 S 97
Telephone:
TABLE 1 - Field Specifications
ApproArnute
Maitnium MaArnum
Uscuble Slze Appllcullon
Field ofFlcld2 Slope Iiatc3
Number (acre]) S1nu Type 0/. Gru (s) tn/ilr
Mastmwu
Application
per Irrigutlon
C'YcleS
(tnelle3)
CUIIUIIelli.7l
\ 1
f '7� 4 N �` rJ � f:fr\ r.�t .da lA wrl i • 7
r �
1 1
/, J�1P fG[. t-.. vt�L,(� i f : �RA�!!'�.
/IQM
lSee attached map. _
2Total field acreage minus required buffer areas.
3Rcfer to N. C. Irrigation Guide, Field Office Tecluiical Guide, Section 11 G. Aruival application must not exceed the agronomic rates for the soil and crop used,
SG
MRCS, NC
TUNE, 1996

EXHM T D-2
TABLE 2 - Traveling Irrigation Gun Settings
Make, Model and Type of Equipment:
4
�C�CY7`�I[ii\
�i�7:
)
W��!'ri `.Y...�(Gi� uJ
-! i�
/ b '
�'�Srr.
mot] .,.� ��I:.r f j• . r'- �
- - - --
Field Not
and
Hydrant Not
Travel
Screed
(Wmin)
Application
Rate
(iiVhr)
TRAVEL LANE
Effective Effective
Width (fl) Length (11)
Wetted
Diameter
(feet)
Nozzle
Diameter
(inches)
EQUIPMENT SETTINGS
Operating Operating
Pressure Pressure
Gun (psi) Rcel (psi)
Arc
Paucnd
conuiuents
fir.
y-Sq
Set
r, ,
Ibob
30!5-
.9 T=,iorr %
O
-70`
`Ji
di `
e��
r�t✓'�
jb!'U
�,
!�
!k
tl
it
� � iY
L
S.Zb
. S S
—lc�
�, a
,4
!1
,t
6
300
,4
t
tt
JiO�
, Ib rs
tt
�"�rt
:
7. ?w l �Ji�1r.1r vr.
�f/I ealKv r�r-'r
f Sce attached map.
25110w separate entries for each hydrant location in each field.
3Use the following abbreviations for various arc pattems: ): (full circle), TQ (tltree quarters), TT (two thirds), H (half circle), T (one third), Q (one quarter).
May also use degrees of arc.
MRCS, N''C
!LINE, 1996

TABLE 3 - Solid Set Irrigation Gun Settings
Make, Model And Type of Equipment:
Field Nol Wetted Hydrant 5pucing (ft)
and Number of Diameter Along Between
Line Not Hydrants feet Pipeline Pipelines
OPERATING PARAMETERS
Application Nozzle Operating Operating
Rate Diameter Pressure Time
(in/hr) inches Gun (psi) H dram r
Comments
]See attached neap.
ZShow separate entries for -each pipeline with hydrants in each field.
MRCS, NC
RUNE, 1996

TABLE 4 - Irrigation Systent specifications
. Traveling
Irrigation Guti
Solid Set
Irrigation
Flow Rate of Sprinkler (gpm)
g
perating Pressure at Pump (psi)
D
Design Precipitation Rate (in/fir)
Hose Length (feet)
d/
XXXXXXXX.
Type of Speed Compensation
XXXXXXXX
Pump Type (PTO, Engine, Electric)
Pump Power Requirement (hp)
Ll
t
TABLE S - Thrust Block SpeciEcations'
Designer mnX provide thrust block details on sc crate shoat.
LOCATION
THRUST BLOCK
AREA (sq. ft.)
90o fiend
Desid E3nd
Tice
i a,
P 1
a, 6.3
Sec USDA -MRCS Field Office Tecluucai Guide, Section IV, Practice Code 430-DD.
EXHIBIT D-1
MRCS, NC
TUNE, 1996

EXIEBET D-5
IRRIGATION SYSTEM DESIGNER
Name:
Company: MAC — — — -
Address: 0404 BOX 1 �05a_. /I ✓Jx,
Phone: qlo -log _ by sq AY*. Alrb,).
REQUIRED DOCUMENTATION
The following details of design and materials must accompany all irrigation designs:
1. A scale drawing of the proposed irrigation system which includes hydrant locations, travel lanes, pipeline routes, tlu-ust block locations and buffer areas where applicable.
2. Assumptions and computations for determining total dynamic head and horsepower requirements.
3. Computations used to determine all mainline and lateral pipe sizes.
4. Sources and/or calculations used for determining application rates.
5. Computations used to determine the size of thrust blocks and illustrations of all thrust block configurations required in the system.
6. Manufacturer's specifications for the irrigation pump, traveler and sprin kler(s).
7. Manufacturer's specifications for tlye irrigation pipe and/or USDA -MRCS standard for Irrlgatlon Water Conveyance,
N.C. Field Office Tecluiical Guide, Section IV, Practice Cade 430-DD. 1
8. The information required by this form are the minimum requirements. It is the responsibility of the designer to consider all relevant factors at a particular site and address them as
appropriate.
9, Irrigation pipes should not be installed in lagoon or storage pond embankments without the approval of the designer.
NOTE: A buffer strip feet wide or wider must be maintained between the limits of the irrigation system and all perennial ,
streams and surface waters per NC Statutes.
i
0
NRCS, NC
JUNE, 1996

9661 '2Nfir
DN 'SDUN
-7/ w1'y7 J, %4;r V 7 v 7-7-3
IWO v %t4^i
I?/-
Pv -
7 "kv 011
fl-70
-7 -v t�' '4 �r J"d
2? r.v '7
vj
'03
'T"'* y
y
; i, ' , , ,' 7
V-;,
t'v' -J
z
y
V1
%-
I DIP
A�, _S
'juotudmbi lin jo zououoltnui rT!Ing;).i PUL' MIUMD1111M '1VKOP-jn1jS 'dn-p3js su Hans s-oinpz3old zpnl:)tq
Odnspiu2isap atn 01 JU3MIA110" hags ISOhags JPj!L111S T! UO 10 ANOJaq P;)p!Aold coeds gql ur w;)IsXs gqj jo uoijialado Dqj Nlj:)so(]
uoijivado 1113ISSS tIOTIT121-IJIJO ;)A1jr.1JUN
6TONW-11", I

I j
I 4
I
I
I
ci
I
�
I
I
i
L4
I
I
,

0
WON
0 W-3
JAMY top!)
TIS

FROM. 2.
PF wo
P
10, M �2 SQ SERIES
. . . . . spEdnrATi6W,..,-;7i-
rSTANDARI
-AXLEr- KAMEkEA LENGTHE
'OF:H 5E', �-AVAILABLI
25i 6W�
S 'NU;RD FEATURES. TA, A M
Homi
4 hp. OHV engine—jf • ina Singie cwt drive on, rumms J�
'd* iai6a it& L-�-,
tation tir6s
-x
;4v4-gallon-aluminum -fu6l
• Y
Automatic - - r�. � ,
guncarvstop?§��, I-M—n- -
Best:qO!!y:-24W -densHv'--
e. swrtch .1 14V iV
F-,HOsd:bui(d-up'Wety
3 wA&61edhigh -d&dd Wes
F
L Vi *905N71 MAN ,,-wcart andItOyAnqdevis.
;• -41NA'25,1
I$C brake to prOWent hose rec6it.
WELLER S iqe Son Rl 50 Gun
FE
kit4or gun cart. RENCE Litt Mechanidal' speed
cpTpen. ation
js� _s
'OfX JON �5',�FEA FEATURES T,' t8'
mgth

""y� +€ ., ,� ,.�.� 7 s � �,� � '.',1 � ? � }r�#frl�[� � a7A'7 "`.r4r t f 1 r e; •'� s�]is+' Lr '1 ji. +.'l � .�j ! 1 L , i s { °' j i .
J i.7, !}{ E' dr + �;r� �- "fir I �' S L tly� r• '. ..3• ,.L' '�' ••,, " I o, 'F•
, ��.' �.' r j aC }t��r Yak+�'r��j' I ea+,kW� ; 6L A, �at y,�",C. •�... ,� 21.- -'F .t�+ �,.s ,�� ?��-r1�4:1R'+k
.Y; s �r ,,���,�' { t.�..j�i'- t •r x.• 2.ia �O CG �^' � .� _ID 2 'F _rM
r:. 4. h 17 die 4 *ip,, •ri f " 4 •r~ ii .i m ,Z { fS
dW71
'
i'.ry} �. �: •• + ' j /• r i. YY, .1 r`- i� � I Y1 fA ', -.Y1 V! ,�i. 1 1, �j;
•� � ``t -i..• { _ .. _ `�Yjtr� f ry •_ � t ��}, O �'w � � � r 8'
,. i� ° 4+',' q f�!r. w I �'1, S t'�• f s� r :F,,,ai f I�,,�t'...,y"2', '"*
F r"1 ¢�
2 .I' J' - 1 • :�. i i � •T+�',1 '• y•�P i4 : '�" r 'C7 [� Q� � - ' � .� s- ` �'•� � CC
�.a �tl, {' 3 j� I, j - ,41y" t `•-j ,; C4 r�. F - L '•@ 2 I 1 'i �' �'�
, r 7 ", y F_ 1'r �y J., ds6 �':�i i. �. .�r ,.r- � ( I ` ?, j � ° u. � tl �' �` i '•'''
'
4 �• �.���m'r ljiryy..i�_. � a �� _ j �I }� f � it �YI�,��,��_ �T�C �� ��j � =�pe
roM
+o
t4 �I
.�: er+p .�, t•,:= I_,� t - k �.._1t ,r �:. I rC
AV
J' �g1 �' r ' �i� C i• f j w Z,RMAM
N IN CIA C4.
c e
♦rs ._: ii 'dm � tl. I � U' W .CO t0 CO � F # � �` '� ��
f;
.� 3 i CC � • ,
II'.,.
� '� .., , :. `• J ,�„ k.A�l' "�� '�. �1J ti- fi..- . •�j�e '� t ,i+;���, , iza'' f �� '{nlf - � t,1 �jnL Ia.:.k.a y } :7 - ^ �' -1 Iz•h. .� ` nrt ti ` ` •ni
I.'"f i +��' t 7� . ) i•' �-, `�!�•.i� � � �llx Y. �,r"� �: '�``�� i e f.J�'�y 'y - � q p� �G , r S� t,,. ,.. '', .e a l • �a.'� -tr' ` r cSr'_ Ir t ,1, � ';�1°'q� f; .� �a „K ,.
Alm cq
:w�. '-, �^ 4 k dr` '-� 7N '# I J �-+ 1 i•.. .� l5 ` I fwt t '• i
A • � r' :�.�.: � • -!i , '� L f - }
.. `4jj rm �,j• 1 (
4. {{ J,� �• c 't r'• i{ -� 1 e'� � j:
I
I J' , ` 1' - yr' 6 t 'f i• J,4.. •.� r. � iri .�, i7 ) �.�'•r .L :•2��{�, j. : 1 F..
I ,�,. r. f7 r. S i r'i, a• •i i
Z'"• + ��11 i �'rL I � � J'e �1}fJ[ i' 9� w'lO,�r�'. rt r.� Es,' � 7 � 1, 4 e .$ 1 i of irr 1, �t�l'r y`� u•.,¢'
C.Srt '• I r�Y.;1. rJk 'fit r 'F 4' F. +• 1 r �`tJ a 1Yj k 3 a E, 3 a�
t , y• t ' `;:+ I r .k x. }�,i ,5,. wy°,�� IwA. J:,.0s.: ¢.. 1 rl 'k., ia'J9; .t'G, l'1 �}f.7y ,s 3f,'i. r:t�� � s ""� A Is. -'X
j. + y ,�. .,- '4L r•� +`U'- 4 •i' `t-`w ',' .Qq, Cq. ti} (+j F11 +'_e��,, �..$C `} f. ?, i F �,Irf rI
{ :, � • lq '.k.. } .x' e. r'• .,a � .I m, l� !'` .� � „•. .. -r� '}' �, tr c - '�i}.. e...
. •.R. •;ti ��.? Ct �; _ • I i - - � tfr ;•1: T.1Q1 '+'' �9 .i � :. i °,p� Y .. ! p.
;r, I� r ♦ f „! a i _� i t s}: }-+.,' ! :Y itiv'�- A'� '+'.�, i,<- �l} �':•t s;x �'S+ + i t . s.i : t r"1 °a^; c r' a 1ti
�+• '�':. + i 'I •� 3� ri,:l F� r.� y j`u ,S�,J� ["cl 1+ � `'s' ;'� �„6 � ,�� a Iw, c 71i'•�s 3� \ �r. ���ly'9i
Q«rAA.p.. `' '.r. i i 1 „ i ri'�'t'; �::.E•t �a y-,i.ti '..:.Li { ,, :� ti„ r ` 1. i 7 .,
£� i �. ��, r` . � �,s 19 r•.P• a. r� S ��kd,'' i I.�p y' r a - ; � '� :�' I S' 7' +?j�} Shr'^y 4';d
�rr ,�{{'. ��� r �rLt � �� , - F�+7 •� � r ,I;` c ..�!`%� �^i},i�r•' `ts 7.-��� � ��•. �C it A<- } :; ' 'i : •}e��` �Y�z ii •�']���A'�ryJ��r.F f' rf��•:
r,!, :',, �!. .;T i f rb _fj)}�r�'IaJ � ?, `. f + S 'J°^:G,t"r:S• .''.� .+ d }ii i.Ri,% ;q y� L!'S !Q' Q' p} r j '�� `I• o `."R +bar
�,3Y - j , .j! • 'K {'.. ,rC S.�e�L s,: +�;F s, Wp �N1J "1+ C]' I� '��'e 4r41t",
r 3 rf 'Idti°�{ i tyr'r!. •{ +/ L.'C J� N ;N ti7 c'!. s• rr e� #3 ��',
k' "e r sy;iJi f s�� •i f J its s tl !r rVi ti
��. s- , Y: 7 j itf..w 7 �F k. S{`#t' �f ? I r i Si S' k.r `,i3•� � �'�
�r -,- ,: 'J y 'i�J?�. .q ': I r.'' l.j.✓ f'y ti .�+j� +t£J' ,(Ir��,i ft -t h'..v ! ,..`• -.e� il! , * � f r r �{.
yYr �i �W r.. Cfl. Id Y•• 7 1•• �r� 1 ,} �C( k.7'
I••; ii• � A t :� ! ,v ',i r'� Y41q'r fi•;•tva2 ,1.. sf'""J rs � r '�r 1 „xr •� �I ,f� p -: {n ++n.
?r .+. .�,1 i�, a@t f>� i F �� �t,t -p• � 5J �'K T i'
I
�.. , a.....-_s. r�i as 1�11�'• p L
�;r_ •! ,) rit ml I.f J !' { S ^ - rr• t. 9 a-, �+` v. �, ' Q.' if; Q �' � -J I f 9` ,� raw.
i •t 7., i• : 4..-� ,, f - :�'-K d �� r. J... a�,y . r,. J f a F� M1 ,'r` � i ire C5 �a '.ali• �.� w •i _ � �. � .1. 1 f
s, •�
I ,.! r, •+ y..: s� l � i s e y:. �i.}y,', •• f' •,�:'!S-w+, li, y ..k �.; 1 ,. �, � f2<as ,,I '3 7"1 , .�lk•hi�7 V�
I .a ,ij 3 qDC{. % 'rli { 5 .i..- !w'' M•"! , <+1"r`n-4 ,: ,,, + A`. �.,:. I t�
y, I. 1. w� � ,�I�• 2 �li'r,^ �'! 1'J"i�Yr' -,/. i 'ftilr'; :' •s11..� '.l�i �, 'i !�' ,lam r• ,. !' r,,a �� '' •7 SI ;,f.. '1 C,�

4SAM = —FROM _ —•
P_2_____
7 With
-F
IT' the esigine runaing, adjust the puliey.pontrol luiob iustil.tne speedarricEer
reads the
_ _
_--3`regriired,retricve rate (from the:grevious=step )-ROT;
.__ ._ i! ry 'tY mpu,
J;• L'S'. •5Q.° :vNri4 -CI:C4 Y }y S_v. •:is .7'ri'."'1...
L, !+,
,� _
Y,-'jf;Qpljf
_
- . .. _ �-__�..� a-.�r►Tf•1TPr . 'YL� _l �...1_��-- �_�_ aL- �_-f•� _w - • w:.�•�.
�. - __ __ -, ..
-- _ Flr are retrieve rate ]s°set or cherlcest on the second, thud`; or fourth`IayeT,the ieiired:reirieve� 4
- - -- -
_ jute must be adjusted to the "corrected value" for the tayer being loaded at the tune: This is
easrl d }z y _one byrefernng to the chart attached to the machine next to the`s g -
,"corrected value" ectl `� -- , . omctcr .Th!
_ -• = ,� , ; rs�reao dir y from the•speedomcter *
S If you are unsure of yqui retrieve rate`fai'any reasoh; manually checl: file retrieve rate by -
measuring the hose movement over a three :.(3) ntJh6te period.and average this""
easuremcni
��{divide by 3).,:
-
1: 9 Opel the access doord engage the disengagement pug CIose asxd secure tne"daar:
O Fully rtlease the brake.
"i 1 Make a thoroughrvrsual �iaspectian of the of the machine s function to,insure,pro*'-o
- -- - = peratiori
befare.Ieavirrg the machine unattended. - - - -
7�AmPLx.-orkk i 'YE RATE
- r ; ,�eteTmine the retrieve rate required to apply a 0.75" application io a freld Z50 feet in width.
' A l3250 model traveller is fitted with a Nelson SR 15p n. k J -�� 'F �-~
{ gu The gun has a 1'.18 ruig nozzle
bintu'ai 70 PSL ;>�,, Y w -
���- •' Froin:the NeLsoti guts chart, find the GPM you are , pair: mping-under_the.novl
e.s=-you
"'havein irecalumu tells you that shaded.blockunder he 1 18"€ring nozle
- T tlre.gun is'flowigg 243 GPM.
•.. From harf 44; determine liow long it should take to;cover one a -i ( ) ere;"in-minutes,
1 `bthby crossmg.tGPM (from abovey application of 0.75" .Tie`siraEded
block tells ybu thatit should take 81-rxwiutes `
From #5, determine the retrieve rate you need to obtain the desired application of
b Jcrossin the tune r - '
u y g required to cover one acre (81-minutes } by.the lane
spacin 01feet ). The shaded block tells'you to sett the hose retrieve rate at 26 .
mcncs per minute as a starting point:
The gun°sliould`be set u so that the 250 f
P ovt"All rs covered plus•sufficimt overlap
z� { beyond the edge of the crop } to provide ade�pate watering at the edge of the field.
T ; fN Es Y? eep�in��rnind�yjtha4=t�tjhe elicits are to be used as a garde only Always chockthe acival
-OK -'%`•lrcatron`rae� �T+NF i�rr�• _^••.' '3'--5i:, d
sU-TR�2,m�Vapp 3,- gauges to e011r[Irl th7t the application rate rs cb..M,d-.S�--
r U i.....rr ! i ..Tx aaz-., s a r 3S-- •s•a� ..
*>,�, a s .� -3 - • Y �,:r a S -A, S ? � � w� '"�. f. M-zc.,:---- - • '•s
.k Mr-
Q
117
♦ ♦ - _ � -'S hey ' ` :€5 mot• f --.,t .. i.
.. . K'.4?.Y... �' e - �' �:i ... v .. Yr, . i - 1 vit "11�?..."�-e � •' % yjr•.✓• -

-... -_ � `',-�_MIIVUT�-itEQUII��3 TO WAT1�R-ONE {7.-ACit1� � - - �•
+, a
- ` - . PRECIPITATION RATE (ACRE INCHES) - -
`,GPM
0 25 �� O.Sa" 4 �� 0.75 _ .s•_1.fI0' _.I.25-l.50_- :: L75 2.tln �,2.Sn1,-
�.,150
4 45 ;_ ' 90 ;: ' 135 180' ' 225
270 315 : 360 453
.ZO.a'
34'��` d$ > "-1Gz �" }: I3a `' `:`!
Y
.Z38; 272 340���.W
y250-
t'r:27�r54 ri r « ,IU8�.. '135_
216 E� �` 272a=
�31i0`
=23 ' = 46 (i9 92 :- I IS
138 I61 184 226
350.=
�14 � �`-•�$'-- :.;7,___�,�--7G� ` = 95 y 114-- �; ;- �3� 152 �
!}:�„
.
_
102 -4- 119 136 T170 �
454 -
15, _ 30 45_60t.75151r'`-
sl;a-28L�`
,
w42. =-56 �: �70—_,
SSO
ii2 24 36 48 fill
72=. :84-y 96- '123�"i
=600
► = 11 >; - 22. ' v 33' '• 44 SS
66=� 77 88 < ' I I3
650
_
= -3 :: 20 :==� -: ' 30 � : ' ,.,`.40 . ', 50
0
6U 70. .. _ - 82 104,'= ..
I
..,
_.
_-
RETRIEVE RA'lr'E&INCHES PERIM NUTE� rs '
- ANE SPACING ( FEET.
ACRE
—10—
139 '
131-:
139 k126`—:�'116
107
-IflO` __
104 •95.. 87
Sfl
: . 7S i 70
65 ;'f
420�.
25.
I05 -, 93 84: 76-� 70
64' -60° `56
52
—Y30
y 8777,- T7_0 - - -63`58-
54� :
"50 r 46-
,=
;35:
../xC«-,es.•^,.
75 (6�. 60 - ,'.� 54: ~ "50
46
43't 40
37x
_
-52 47 , �a.44
4(} '
•38 - 35
33
4
58 52?,z.z 46 <._-42: _' = 39
36
r
_ .t,, , 31"-
Z9
Stl
`5T , , fit {, - ' 42 - -_38- �_ 33�
32 =
30 2$
2b
-.55 ---
--4g-�= �#2 38 35 32
29`_
�27 .. �25
24 � :
60':
44 39' 35 32 4- :-~29
�7
:. .25 y - 23.
22
36 ,.t - :32J ^T=-;2�'.- 27
-25
--23 �.-2I
_ 20 <:
". 25
23 '
21 'p— 20
19
:',
•: 28 25. i 23
21 `
20 K 19
17
_�_
29 YX„ ,
`33 -24 -.��- : - 22
� 20 lei— 17
16
2S 22 21
19
- 111
_
.16'
26,: } - 23 u ` 21 .. 19
18
_ 17 ~ �:.,i6 :
Is-
2
,.zx
: 21 . I9 I,7
i6 -
� � . �.�
15���° 14
13°
c,.•, fun wy _5 � - _.,-._. - ``- r - .•--�-- '-
ryt w_4a�ln fed a _rtufnrxr r� M.
i. : C _ rid • L'�'S-1
i z°�it•Ta - ..-ter F _ - x Y'+'�3 _ <.r.r

"NEISON450
Nt
lie11
110 41
4,
I f
SIERM3
BIG GUNO
'270
MAgJCTORY
ic
7,
F' 8
.0 -RING.,.'.-
jj-i18:MG41
1.26, RrNG
iOJ
M.G',ZOUJI,
RJN G.I;
.3
.4)
I GPM"
1: GPW",`
DK
t,'GPWI�;.1 Wtl-
J.GPI�1,�!, �-MIA.� 'k
"'GPM"' ­D1 A
GPM VA.I
245.',i
.13Q,
�4*165*­Wi�
L2 05) 300tIIII
T,
320
'.X5
_,f"130D
��5 I;;
1.,"�'4350 35
'lit
7
-
�2,275
-350
8 365.
yT"
'is 5
L T�',3 10
330-4
:11, 05 - ,3501-
380 -
go..
128,v
,270
i80'
165
360
7-.210 -320
LT
1'3
J" 90J 40�
.11.;1335 6
-_380
1, .0
4*5 '395
90
135
29 0
175
10
223 330
275, J.,,,,3�0,
i'�335 310 1
405 1.
- 390
-475' 405
Ic
'43,
-300..
1 85
320
235 340
1,i355 3 01
-..,g
1,!:
I 'S '415
vio�
150. -:t,310
1,,195
33?-]..,
247 1.350
305," 37D
111 390
1
0.
425
''
415
204
-335
�L11W
L.7,0ss , a
,
465
i r4 2�01.
4 5 '43 5
-
ji-
I
OJXAPIER­�_.
�ji,�' 0,8YMERI:
'ItOTAPER,-
i TAPER,
'1 :2,TAPEW'.
1"14.3 TAPER
IGPM
GPMDIA
--GPMi-•'JDIA
!GPMtDIA.,
;GPM, -VA..'--
'rGPM,'t-1rj'DIA".
1II ,,l DrA..
I DO
250
130 270
165 1290-
205 310
`255 330
60265
1
143285
192 130.5S,
2iS 32"S,
.'1275 345
L3036
I`10
1 8 380-
710
120-
290
135'.
�00
I'A91, 320
245
�,��-340,
�,295 360J
3.110,I
11' 415111-
3 9 5
.SO:
1 128
29D'
165
310.
335 0
13� 5
J
.315 375 } :
3 .380y,
i
135
175
.320-.
�1'345
.27 5 4�:36 5
'�"335 390
001
475
J. '1425
Ak,
1'300
1 95
330
5.
3. 5
2P -1;,, 375
4 00
425�,
00
-440
�235
01ce.
�.65
3 05,,,­,#,� 3'3 85j� 1,
'iQ370'1 II 10� ! "
'C�445 111
I -,
W'43
-I-I
:i,
375,
5: 4 20
440'.-
',460,
,NOZZLEi
rfkffiafice data has
e1scyn-IrTigation Co
g
11
N, 4'�
, CowIS apprOximatcli2/lakW0ie_20trajc�yifig1b kid 5%169 forthe210tr*ctoiry ankle,,.,
bccq� obtained, unider'id clal test 6&ditidns 'ani d may bcla&iplisel ff&W bt3;'�I;4nd, poor hydiabl.ic entmnc
rpoes no representa ori regarding drop] 'ii t
ration makes et condi n, uniformity or application fate.
, r
is NELSON BIG GUN
conditions or other factors. �•
F!

B E R K't L E Y P U M.p S
-TYPE- "B" RATING CURVES. .,BERKELEY,
ENGINE DRIVE
'CURVE ------ 7-4117-
DATE. 3-1-88
PAGE ?-02
SUPERSEDES
'Curve 4117 P Z02
Dated 4-:E8a5l-,Uz
C.I. pmiw a:1e63
mmL Is& H-A63
VAR I GUS ILPAL c"w
.L
kwwN-;-.-Kwww—C-I- VoL *a:.- L-3wl
mock. se. L-30" 13-1/2" NLL
MAXIMUM WORKING PRESsuRc 247 PSI
ws iR L" E3
I
-A i,
30
j. i.
.-H
IT,
Jilt
T'
I'
2D
f
j.
'i
il-4
1-
41 s
44
-44
-660
5W
•
z
Z 400
300
X
0
100
—0-
7
.4
1
- -
4.
- - - - - - - - -4
......
.
AD
41'.
4
A.
H+
.... 30M
RPK�H
k*AjIUM
........ 4.
4-
t
4
1;441
...
........
4
'T.
-,240(
RPM.:.
.......
•1w
-
T
X.
RPM r
_t+l-
.7.
.........
7-
Q,
..........
. . . . . . . .
i6(x
RPM—
.
........ . .
..7
J:
. ..... ...
a
+!
H-1
;`
f4l:,:
l-qJff
+
41—
:t4-A
:JJ:,
fIAL.
T
It•
T
-4
+--1
44L
-
4 4
r4-4
+
.1.
-hiq
I.J
T-
- J�
BL
P
0 100 200, goo - 1060 1100 1200
CAPAC!7 IN ILS. OALI.ONS PER MW=
r-7046 B-odw T-2554­- :C-7048 10-27-71 04" 3-29-72 mom B3JQE3M
400
150
o
21010
100
Q
50
0
hwasol meoww MECIL L
F-wNwM72319'
MAX114LW WIDRIC1044 PREssURc 266 PSI
Oi�"�L��7w'939— mock NiL� M-1939
COW , mdrid, C. I. V, - ., , , - _ VARloUS:-,-ILPJL Crd..
I — C-1. , , - , L ";t '"21 10-7/16- FuL'
'�
e
ra
■
O■
lm
MEN
EM
wwwww,olm
ME=
�www�l=
IMF
=ZZ
-on
mom
os
22=
me,
MOVE]
Egems
Kim
Il OZEM
mill
0
J=pffn
EMS
awsm-1
Rai Am
In
I spa
a0
0113
0
am
MR
I H: I
M
0
ollml
M
"I "S
NIU
2w 5w
7W­r600 9W 1000
CMAaff IN UA GALLONS PER Momm
C_"95 T- 2ST3,
6— C-6695 0~ 9L-3-71 0- 3-29-72 Mao m'B4EQM
rnsu

f. , -
:.�.
- Diamond
�Diamond,ASTM.,D 22�#}�
'
Gasket Specifications
�IP_S.:P_ra'ssure_RAted_PVC
PiPe_, �
�,
.Ar)Drdximate
66 A6r'_Dlrnensl6ns
�
•
I ..ir h
1 [. i..
! � ..-s. ram-, - �a+�.•--+} V ^^ r �, _ _
-r-�-
�
- _ +�-_-'f•�- dT .rb. .
A i . -
-
Y9i..
_
,�..
I�'� =
�
'Gasket=configurattor;�,locks=gasket In�lace and_ �-:
-
I--
.� �� � � � �
---' �-; =r- - ----- 'Prev ents.flshmbut h-in g.`�--
_
�
,-•�
sea'for added pressure sealEng ca
'.Chevron l-
,
II'l4.
F.-pacity:'
-;
-
- ) .._
- - -. --- -
�'� T
_ `y—
3-_Compresston;'•seal — =prow es- seaE udder,
t
vacuum.
4: Wiper beads tti dean'spigot end=`� . .
ss
4 Diamond=•-ASTM •D2241 -.-
;�
[PS —Pressure Rated_PVC—P-i
Rieber.'G6`sketeci Joint`',DimensEons
�: _
-A.T
_
w Stze =-r
Gasket Race'"' Socket Depth
,,T
•2::
3 166
3=
'?111: T
3 719 .'6 000,
�- A i•, `BE�'�a
_
-I .-
' -
5.603 _ 5.000'
_4
r 7 6h.
_
8:2T52T �6250s,��
T.
;
10.42p 6:500' i
Pipc +• A Q D
�8
12.762. :. T500: •
_
Size Insert Socket. Diameter
14952 7._500
:
.4-7116
'*[y.
S.A in
F
6-. 5j.,� 6. 7 13116 .
D-2241-Pipe°Dimensions
� U
" -
-----
7 10 M -,
8 -- - — _5 1/2 6 B ._ .. _
io 3/4
Minimum -Thickness Thickness '
l
In- — 6 ---8 1/4--la 11/.16—
x0.1765 SDR.13.5
SOR-21 SOR 26 -,SOR-Tt 5 so 141
ire CO{�5C+s40_315PSI
_200Psi •160PSI-':125PSI 1o0PSI':
r -t �t1:'.•t;.� J ^r
840 ..109 062
;~
347
.060 x
:1 1 315 1.133
.063y
j'�. •1.660
079
Short`Form;-
-,ao
1'�=" i.sba 145—
.064
090-o73 5e _
,s
�Specificati-on—fa'r—"Diamond—
2 " 2.375..154
-113 - -.091 . ,073T=;:
rr'.088
P,VC Irrigation,-_ Pipe
-2'/:'` 2.875 .203
137 110 s`•
'•`.
'
ASTM-D224I-SDRA1,32 `5,26,or2I
3 3.500 :216
167 .135 1 t10
^_ T t
4 F4.500-•- .237.
21a --.i
Diamond PVC Irrigation Pipc°shall be made of y-
5 .5563 �:258}
265 .2t4
wmpounds conforming to.4STM.D1784 with a
6 '6.625�_280 ,
"•
-316 :255 204 1G2.
�
ccll classification -of 124S4B ; ;Diamond PVC
8 8.625 .322
.410 .332 .265.
�..5
Irrigation Pipe must"meet alI'the dimensional
�_IO "t0:T50 .365�
511 .413 ' 331 F 262.
4=chcmical�
and -physical regttrctmems-as-outlined
-
12 12.750 " 406
.606 490 , 392 311 •
t'
in ASTM D2241,�Annez� ANSi/ASAL- S376.1
4.
and SCS 430-DD and willzbe sipptied'in-20 fool :
d'slPS�Pressure.Rated
PVC�Pipe�co'upler-
A.
+°V
layingjlcnglhs•
tri7o
ntheASTM-D 3139aefs
r .>:
tnggVi f6ravailability-
4 b
i
3.'�"
1
�:-?"
- �t �.1-4Fti _
•.- ,Sj;.�S14fF y U .•1 w "
�• ._ h vo.- .. .
- .. — w.3 �Fi lA'1. .L .
.i ..,�s'..i_- _ _
- .. .x m/.-

Diarnond� IPS_ pressure -sled .PVC .,prpe (2"
PROPERTIES OF
PVC .t2454 f3 (1 ] 2Q) - '+
through .12"j is" made -of compounds -'conforming
Pioperty .
: ASTM 'Minimum .`
-to . material' requirementsof ASTM_ D2241 _In,:.
_
lest
accordance with ASTM Dt7.84._ The: pipe sizes
::specific Gravity
f� 792 ! t,_40,
•tlirotlgh`•=12'}-; are> made ° wrilnr, integrat •
Tensiie St�englh, psE— —
_
D 638
-belles v�hich'._uti[izes -a-,gasker =for 'se,al g in
- _
Tensile. Modulus,-ps,
-
accordance -wrtli; the r•equirem'ents of }ASTM
IZOD 'Impact -Strength
_ { N
D,256 65 _
` P477,,,-1hiegral sockets for solvents cemeni�ng
t
. _
M
heregiairemerits-seiforthr9 inAST�7
+
h- tb�/iniT
T •.:
�-
�-
6267.2.:
Diamond IPS pressure rated; PVC prpemeets` a
the dimension2l; eti
aS1ni-7ES-T - -_ -
,.
as ouflined in ASPWD2241
"D 543
_requirements
t3OL'o Sulfunc'Acid.
iractt=male-end-shall-be-beveled io-tacllltate_�
,•
4 Da ysFlotation dt
er{narked foa�-
jOlnln"g,,arid .refenCe::r-=uaui^ ,..
-_ 5" ��ar > -.2° C_
'
Proper depth' ':of insertion- €7lamon0 furnished
Change in.We,cn!
' : t ! = 0
lubricanr-is to., -be used. in the.join'rtg process ".
:• ` Change in Flex Stiength' �a . 25AO i .0
=.
4 1
4A : . ; �^ '. , . -
-:Diamond-IPS Is�sEippireo if
-- aST M-Od_ No�3-3Q D_::.�
- — -
pressufe•rated pipe
n,,aerslon�al.23�:C
-_ �-
.20:foot. J. 19ths:> - � ����
_ -
i «_
Change In We-c„:
-,. - _t "0 :� I U
pri
1 W11I11711fT1's .F+„y
I
!.,`:' 1. .f— •. _ ' }ti 2"' ,k 4,�• -r ..
_, Cur
Yl' It•I(III' Y -^5-

FRICTION -LOSS CHAF�TS r
:,-.FOR- DIAMOND.PIPE -
4
:< x 1P S DIMENSION.-
a7.
�4-inch " S-inch 6�Incts 10-lnch �12-I66h `- s • • -
Per MinR LOSS IN FEET v
6 f=3 FRICTION -HEAD_ s I .PER HUNDRED FEET
- :'.,_f�-x •-_i.!:-.•-.`. - .s'=,� - ti "..+C._• - _ -S.T^mod+ +F �a-_.Tr._ L _
"� i _ , a+y, ^, t. p ^1.t `i: S r a _ { - -i.yR•"i 3. : t»� t' Y.e�wt
- 180
1 73 -
�tv
� +'sr
71_
Y.' --•T � t =-4fir ti - � C.F.
tT"`r .; ar. �i , '.
_ _ .
r �
#r.z- - k.:. k�+•r. .,.- 1w _, .--..-.•-..�-' >}.......-.:=«f;.-- �..;'.G.:.s....:Wa+-c-�...
�A F
-- wYr: t -�i.
: t)
22
228': 81 :34
240-.
_ = 2.67. .'.40' - 10
_
;2ti0
1.10_.. 46 12, -
_ . • ° 280
3.56: . : 1.26 54' - .14
7300
4:04 u 1.43' . _ : .61 - .17_
-T320
4 56 ' 1 62 . 5 69. - 19'
=.340R �5.1Q - -i:82 --• 7.7 -.2f-
5 67�, Z D2 .: 86
�iL
4 380
" 6 26 2 22 _ ::95
7.400
'-a'
, _ .26!
6 90 2 45 ` =. 1 04 28
10
. --.}, •'• •.�.., `•-- -' r^. •�-. r a..y .:. ,'.%. Z ar^
420,
e
F-
{
s
A
_�, `2 92 . 1 25.. �..34i
1:1
4,_
3 t8' -1:35T :37.:
`
344 146-
-- �•-500
- ---� - -_3 70----- 1 58_-' -:43 :�
,w
,_ .15• -
- ' :� _.m
:89 ` .52
.18
A83 x
tx 600
- 2:22 61
.21
....096
..14, 650
_ 2.58: '.71
:24
;
110 •� ' � `�
-700�.
_ --2:9s--8 iµ
28 -
125
",750 .
j t-3:36, -.93..
_32
:141 ,•f
�' 3:78' _ ' 1:04
_36,,
. i58
6 850'.
- ,". 4 24_ 1A7.1
:40':
175 ` s,`�� • ;
t F 900' Table,based`on Hazen,Williams 4.71 - - 1.30 •y
,
� :44- 194 _ �- �` =
= --
"equation-Cw150'
`
.950
:�'5.21 t44
49
.213
, •7 �, .. 5.73 • F . - i .58:
4 54
•.233 � r
r'
1/ To 'fin,friction Head Ioss in -
PVC, pipe -having a -standard , - i.73
59
254
1100
dimension ratio other than 2.1';_ _ - - 1.88
65
1150 .
the values in the table;sfiould 2.05
.298 :.J.. .
_
- - r 1200..multi
�T T
.-:
p!_i a d-b y� h e 221 ..
.70
.76 .
-.322--
]250
appropriate conversion tactor� -2.39
�.82
.346
' 1300
F shown below: • ' 2.57
i)
".88.
.371
1350
2.76
:397' '
_ 1400
-•2.95
..95
1.04______� �_r.�423 r :'
F `,1�450.
sDR PR F, `. 5� z=,_ 3.16
451
- 50p
-„"
3.35
1,15-
508
{
21 200 PSI 1.,00
-
` � H 1fi00
+ h
26 16U PSI 91 �_ . .
3
1.30--
n.
- "
-_568- -
17
�32:5- 125 PSI :64 ; _
�"'
145
632_
. 1800 :.
;1900
41 100 PSf 1 785 1
-x 9�
51 ` 80 PSi� - `7
_ 1 62
y
698E r
> 2000
J �# -1
1 79
84p'
Loss below bold
line indicates:velocdies in excess of+5feel per second
Velocdieswhicli
exceed S leet per seconcs'are notr:ecommerided
_
4

INSTALLATIONt, ��
Table 4. - DESCRt�T10H OF I:ASLEVMr.HT+ML ATERIACLASSI}7C•ATlIONS
i
_
O PVC should be assembled and
SOIL
CLASS
SOIL
TT^=
orscRtrTln� n}
SIAT}RIAL•CMSSt }iC AiIO♦
= -
Jramond Agncultural -Pipe
-- -" inst' Iled-with-uniform-and_continuous_s�spport from a firm
_e,.;, I s.,,•_
_
:iM• ' ;,t ;.;.:
}
":.base in with the -installation -procedures provided=- - --=_
=
_
...L.,.-� - -
-
-accordance
in ASTM D2321.;anif the Installation_ Guide for PVC Water . _
�� n
WA.}�;�s�;;;�,,Y;;, ,�ti;,.,r�..lr�
N. ril r. .
_ 1�
izededition -is avai lable ,. from your
{a'_'"pocket-s_.
�.:. Ra..v w•rrd IA��'934 -a+.
- �-=-.
`- ".
from Diamond Plastics Corporation-)`
Q
w-�„,•-�
reprCSeR[aIlVC Of
[.r.rI<.c, M#U.[i. !4-41—as4
_
.a -
Einbednient materials are to b'e In accordance'.wrth sorl
• :
- -
Snr
w�a-i a rdr awd r •e11T ranQa lick w M f Yt .r µ w 41C «! r e
-
T-
cations -listed-under_Uni
11w MrwMra +:..�
M 4.+..n
,__—classl OSoil-Cass)ficaton
Syst m ASTM D2487 and ASTM 1]r_•;_
�' =
a
- _ -;' .- ^i• �_..=zs-+«'ya ' l+
aaw 111*Sw6.V-
-"G1-
-s.i7 i..'.!1-
' mating surfaces of thebeIl, sp)got ands lz;
Tc'assemble clean
j- gasket -gasket' lubricant (furnished by Dlamo_nd
t
,t..�; ..am`µ
,[,.,... ,+-•�•. +�R.. •.-�» " `
'_Apply`
-Corporation),:to the entire spigot eiid;up'to'ihe
x
"suSoky
p-� M `-
ter=;Plastics
liriiricant fa the contact surface
-
x '
'cu�;;;;�,,d�,;r� ;;r,: ,,,•,,, y�:�,..w:,.. _I �`+�-
refeience-mark'.,Also:apply
of
'S.4
„-
-
IV
FSL•
laseaw:c Nb. `47 U_ uwh. r..1 M1 4= + i..sY r.w
s,. _
'pipe alignment, the spigot into
Y :
s6c . sav .....� io*..; N.- Ti+With
the rn sI. igbt push
a
i..F.n mar �w ,,,,,,,,,, I,p, ". r• •-11 I
the be11=.Iip to tlie'insertion line. If al pry bar,is used,to r
t
k.�Uri L1^"% •kr.
irl 1 1 Y 1 «I..�
force; the pipe'should be protected by placing aboard
-
YRI
Iwwia� a,74 K.iM,,. J, n. f
,,�, „tl- k,� •„„u,w
_ .},apply -
berween the
r[l�ir.c
If norrhaPforcedoes not complete the',oint drsassemble the -1.
C,�, V ir4
' (L
�4 tld afu.K k7 1 7r d I.w Ola' S L.IwI I...s � 1.:� u
ML 20
.
r joint and e_xarnmc,the;parts_io make cel.ian the}+'are free�of r—
P%...vPui.
'�i,;;��,��„�,;,; ",�ri,;,�-�,
a s Visuall ;ins ct the con)pleted lo)nt to+Ins'ure --
R y
._-
t+T�
iT �rkw
-'" 100 - rr - -�v
rwk:kcNr -J�
r�ob5[[11CIi
I
�' the'gaslet has not been dislodged. '_
.wc> L.4r+`uF - r, »i
-`.....s._ •, fit'-
�{-d' AST►1 D Iql• a 01. Ck S wmul �4i dlrw.l wiTii _It I
' M kmrdaMe �:AaSST.[ D ]p]. Icu tL.n }4 Srr Nu-Mq sine. .'i• GI
.•[:U
-+•f••-. ,.....
<. s-tY..�.•.�-.�.r ....._a..�..__.—"-r-�"-•--•--=""�'r--'-�+r•4-
.'lw`tieo>'d..t.'�,AASTId'D:u7.'ri�.:J.-5^s 4..11'L. pssri. vu_ti.
x Table`s
. -
r - 'AOXIMUIDE FOR'ESTIMATED RANGE'OF_ DEGREE
oh'
f;
f1IS nlP OStImpOrtan[ the .support_'_o-
The haunehing ar
()F CUMYACTION VERSUS EMBEDMENT-CLASS"wND METHOD
OF;YCE\FASPERCEN"i'OF'STA�DARD-PRdCIOR
'DESYOR
_t
"ching should=bc
sU Portthe-haun
VCP�pe.Or OOd
RELATIVEn
FOR;CRANUCAMATERIALS PARENTIIESIS
csfies give in'. te_lng�T
cm4dihe. drIn
,
.. >
CL;kss or'EMaEDMENT
'r=,;
�t_IV
- ,F •ZI i
)�ada�acd
•Fine
FIATFUAL DESCR.IFRON -'-i
Sand aM Grand
Mued • C/tain
-
Gram
---sods-
(iirr4Lar -
-Soils•01-
�Soili----
.
Ch4imini moisirlC [perar nRLc.;
F-71
9•l2
•- 9-IL
.r 4]0 .
-lime4Crd7 K+La
-
' - So.+ C..cAdalioi Medwd -'.
1k ([ Racar irn RcLwr _) Ocncit7 Rance .' �:• •"
71
'
95-100
4540D
' _95.100
96 t00 ;
--
• wramxr'.•- -
-(7FtfT3j-`
�`-,EP1f17t�
Dmolib, Ppnap}e : _
095
wV]
.9G95
1590
• - ..hiarrl. -
(60-75)
460 WI
L643
�95
(100
Comwhdw
y
11>wdpb7e
6M
•v.
(gum
-ems.*-' F
S
�m •_ _�
'EO•:S
r 4[ildi>rro
11u O
1' 6Pi0.
77
Gam..:. -, .5.'
�. "tom° '
[d6f41`
• [SU/AF^"'7
!T h
Deflection Chart:. `'•
`
�
Figure 2. _3-, e
l
- L-'c�E'_'Hi f.
Jl.:.-.•::.•.�:::r .y:
fez
:: .� J
�.. .. s
r 3 sS ,`{+Ct.'- •.
�^
J l %.�.•..
-4
y.-.. ,.. . R[U4K dfAMl.I N/OOMI_ -�, .+i `7 i'.'L .t •.
,�- .• F
•4 �p3, 4r �
.1 ;1T I - -F
....w�, i u�'t `.I -a.!
_4; 'Y Z�
s y, .sfi� .F�Lt���i1. �J
�}a�.�
Xi_�� - ....' . i'• d[{.tliY 11ia Ytl d[.�i.tly1_J11a.tl[d ^�.�_ •ir.lFtl
L a.c.a=r
ti.ti -,
��_' -�.
S _
i _ Y� � ..
-
-•TFra talilc M NI >• awl a�ppiwr�alc L� -
^4s�--rwcl7rd+d-JrwoMdal�ll_rl dlffa'.i [lawn ui uwl i1.r l.nk n.wr alyd p'u+.dc Lud-[au4
d ti7ll.• ML nee. Iw y.Ra •+ •"i
-I _ _ •
a
A
�' `. detip ldt Arrdtrxp •alwn Wald r,e i1> rrie
�a4w arari.[I.dm fa r. _ _
Sy
_
rl$'
ylOdY at Mn dr tl4,.pnR Y[Iila r..
[d

ZO
"l'lmo's
-an.y.'-cohf-guati
on. -Sdm�e ep 9)y
coated fittings'
a
beTfibHdt&d-in-a
imclvdeestacks andhydrant_as,anAnt6 ral partOf.-the
ccasloa11yit.maw e,.necessarylto connect PVC` plastic pipe A6-steel
%4ith a"couplin) caIed-a
CA,pb: ..ne,
rmiiti6mor-rej nnjnevalvesnbe supplied vih
- s�
onn ctiofis-ttqdsket�70pp-
t ...........
-'- -
.for-'§asket pipe.- -Most -thrust blocks
hlri4s.�-' blockihg-ris-requi., e6m6nd6d fhr.�tjL,pl.o'cks_at_ :any.
b-e��e t6:'Manufacturers; .
'Chang6jin greater. -than -100 Figure- 1,giyes-a­n-
-
,exampl_of
hrUst different 'A Pnt­-f&tblocks
Z7 7z
7 77-7,
p
77._.
7*�7
'71
f
OZ.
44
`Tt
Lt,
t,z
-7
E 4!1104 A
. . . ..... ..
to
j
, Mr
A
Ef 6 10' of"d i f.fe"r(.�h-tia.r-,rangementS-�l?, rus - - blocks.,
Example
�4
g�
Em
ut
71

ti F.r
F (_ y r F �;.' ti , S:'3 t u 1 � } . t,.! � d..{{..r� r. �.:}i � r fi. i. � ., } . r' i. , .�' � •� ;'k � � a,�p 't 'f'",I�+,� ��-'hi'�` I r.
, {�,u ,,ti.�� ;'rs.�,r : I��a ':{,['�:-F. ,� �r ,�r � 1�•r.;�'�'� +��. I' i s,-.. .",. t � `tr, ,. r .o �t. 't•.����. rr!'f'�;�� y'�'� :.
A
�,,.r ¢,,•i�..,.4 ,t ?}. �', -� `•i `-i,` ._1 t _q .w`'.Iy zt -m,,• I1 .fi. .�; ',.F''y•r` »I 1 v ,,� {;3'gL 't 1•„{^'�;}!:. i'fy
t +� .I €€ s 1 .��-i' F s. n !` E A . "s•. Y .�.� xry'. � � � y .. r- ti .ri'..�k •�. „m� rx
� ?.i':'• t. �r i {.Fr 4 P 'r. ,, r. I„ .:,`.., 'S , _. .. rr" i - • ra cr . � �.�. [ .•1. ` F 4.
•. i � 3 '�. �yi`3' S r LP .#r ` '� � ,+.,�, h..'h > �.. �.,.. , ,�. ,,. ! i �,r?.., i h «*i
' _ � -f �1{F' �': y �.'•� t F...`[�;. r. s + x'1 M,.• �,L' .r .. i . ,; . , { _.1 F•"'' ,'#: I a�:.� 'I.,�SC'n> i�•r �, - �"•'�-fi
p :I I w,Y'r �i � .o ka'Pi:.i. � :ti. �,: •I. r .,r, (•d �..sr.'�r' !r,Y i. 'j . '?•.•!� }- '! rA� ,.�lr.".' f trM. •y.
r } 1'n,i I.' I'.,,,' r�_I �a`'i � }�'.',i;a' 6 ,� -1'��V �I„ y t•i. r �x :.•i,- C' .� � .! y r,, •�, _.. r ;4, :;.. .I t
j � ;.I . i '.,� " +tat, � i'r r �� �' .-4 t, r •' •' µ, r 'r ,ti �, r �,` •f �� ' � � ,i.. -+.w P, ` 1 _ r .. 1 �r ,,�': ; r i I•'
F I �, `' il �. s . ^ rt+ _ i' 1! r � i7_ + j .� 1 I •! � y '� � i Y' - " ,
f I
'� 'f r "� • �� y �r'. (tt ,Pyki�t t :, , i •n � r ., .1, I. �•.{. .', :k. I _ �•. t -. y { ,:La tt Yi. I ;S,
1 y Al •,� t ti i+ �;`_ }4 r ! a ;' j t--s j O O C"O O O O
O. 1� ri.tfl Ci. LO m N to C�j. a nn r t F
Ql wr w w f t.r }+•; L
aCSS-:r-! • Cf^s.� t,.a_ r •1 .,i Lp ^' Lli•m'
C Ln ,� 2 } r+ N Ri' LnW 4 ,rs �' ; t,
f .. - f • i ,.{s'4 �3 !'ff , -, 1 ep £; 5 ,+i:r t• r�
h .I''7 S:." 11 '� N'_'f.t, {'+ •r
{{�I , ' -�Y' : }.e. •t S d y'. ,' _n. ,.,Y 1, ,U:'�- 7� s: ': ;: n,!!, � Rt. n;. -�., s • ia.,: P ,,ar,,�,1�72z;,i I .4
.P I _,4 '' i_['t +r,[ �?w !' tr M •F-:t 4Nx ,.>l;� �Fra f r<� �ti Fd;',. r••,: 1.71-. y 4 It. l� •Q} •• , r ' + ,�' rr•� _ Y,' '�'.:� ' x1i
d 4 `i I;,fi,�g { r: _ r C Y, t of ' r !f •r a S.
_�: �., r �.. i +•' .e:r. � ' I I h - �V t!•.• � ;� �. ,,I •. t. -, { a :R -p . .. s •
�' VI t--s pQ pO QOd 0O SRO
r `•( f Ix "t' I .`', O; 47 Ln .:Ln t71 rt {V f• m to`b OO
cu .CL Ln M M Gl LO q*- C)m N ►^ ti rt r
! " r :, , . _ i i I, -.r t f , r F .., • I -' `V]CL Q - _ f'i rN O r-1 vi'''1
tQl l i 0' N S'7 Q L!7 I
41 Y r. 4'
71jC." _ •r to I i-
i �'r ++�{; !. +•• i• 1 =, f.. `� :Is .,.G. C7tia
t' r{`` I, i�' i•, , ,, rf 'r �. r I''•!,a :RY 4s�rs;.rtre•'
.. I ` 4} (, .�} .�. • r� � � I',H�:.i'" `a .� •• � 1. ,,,�.. � (• �r^ rr 1,,:-.r x S: .!' J�`- Y' a fi r ,f�t� :.f r!«, � r 01„ +'_
+ `" s .'.,!` �'. �r r«•fir��' a� •f r 1.=. .f. ice" ,.� A. :�� �1.�. �r�'p' � r' '•I I�`: ..,'.._ts
`4 h�'r'` r r.`i ,I I:' Ja r' sN4 1 i I a :4•' ! t� ;a.. r°'.0 �I S� •:1-•i, r 10.0 O d ;O d. III
y !i ,2 • :F �• ,.fir r. ;� 111(fiJM111F •� r,, 1 .U, -� �: } +,s; W r{' O N.:St d''OO.;Q1 co N d Ct' O O O O - �� - •f{,_ :siL
t Fr. {p; m Ifiurl a . ` '1• rt•; . s:{" -t
' � •�, �, � . � �'• �•I� o.r�
1 !'t Ir 'i! r .qr 'r',+' ''a •h r ,i. WO ,na•?'w�+
v�'�� •(: r Ib. t/1�_�,� `.d?r - .n&.;,. .,tD.N G7'Ol �; a: '7" ae =�'i r..L t:_. t•.ti n. .,'r
1y 4 ,• •t: I ..�, 1 r S �R ri Cr7'
�_ 'I!
i' 1k -ice a1, � � i y Lt1';}"` �f>*•: N t+7
'1V 1>14, t_ " r-1 • ,+ <{ •
x �'s i Y'r * aL�r� t •�#�,� �+ ' r 'Itll F '•r'N I ''� 5 `k1
I a•, i~ 7 r4 !��
4 I t ,t[ 5 (: :�• • R • •• ' • - •�~ , . r— sy C 44 ? ?,
ail. (k ! err F :ail � F1, �` �w�7��I+.�•�I �r I' 'C�JIN� t �' •�kLt7Lf1d1170G?C70PdA0 4 1,
C i-� (° . IS1 .!~ V7,jj' { I al LO �O CO N c! Q1 L[] 117 O O
,j••;f 1 i ii ', i} i is r p ,. • ` ��+<.Fr r w� `/...� `� r .. C'VI'}--� 1 Vf f.3."i I' N ta•fll OJ lD 1p i }
0 rt
f s a 1 i .r #. f' d1 w {' :. w• i +• p .. '.%. a i O F G 1 C r �, i . O P t C� Ln O kD a s
- I }.: 1 fro t .r..• � a.�. '! -.rF , : 0 U {, j 'r_ ( . O .t. -
1 G.k r f' k r-: . r I 7 r° • f } } ° r r..r. , I
r I' •'w« �i �` 3' I F ,C1!Ew.L' � I � i �'} V1'p 6111 G7 •� OJ � •• Y'�_ - +- -�.�. _� , ,.
4U :�. E {{ r-;4,.a i' � ,S'r r`�.- ,.r,ar, ((.. +�_ tR, �V1i'1 i'_ ,:,�. ►:•r- t, I-tl S�'ti; +. '�III i..' -.. irL•:+1' '`+l �•'". �•�'�.k.. ,}.I Mks tt .;r
': s r _il qq r:'- • { ( t'+:IIc SM:'$ti� U t4dC•r41
rr
� } i �. : �•rl i °.�t rl� '� r �:�,,€'' { t� i �,"ol:�, ±V' w.tJ1,'�tO 'Cl #". % c � t r i.✓`�j 1G=r +r� ,!: `t.
• t -� , _,r' :, :�'x:, 1.. �Yft.� 3• ;,ia,�a ++,yS: uSl- •A 7 N + ;•,I, .V.. - is s;!c IY 1' i'.y
it, "r 4, ��' „N !GL ' 1j 1 +• ''�.'' r• ',fi' ' - 7 yil .::! s. t} . 4{.. 1`•4
{,: t- ( I . i �'.� I � r i, lu _ _ -� .fir, �r[7i.;",r �. � :wn�l ,Si—'!N"S•+ '�-+, j. .°7 .;. '�a' � -. .,v. �.�i �I 3 t: r'
• i q t+ '(,I :v I' s;rt{ 1+ 1�`�rf J' l ����„ " 1 •i 'Jr.. _�_ �b:0 '(�. GJ i'r.v' t , _ Ft 11. ,.�','f, L , ,.r E - ' i r 11 ' ti S �' t �.Il' • QS I i 44 . +, , •1"/'.0 I • - [ _ t I� _
4f ti I I n r K7+a Cl:�'V ; Q, V
" L'�' S [ s 1 % t' i{Y �• 4) ,b rd C .r l N N Cf i1"lO'CO O CV , �!' tD
.�- r. I�� .ii., +. ��' �r�,, 1 1^ „J. 1 IF, 3. .�.,.."r: '� O�'' 'iS�'ti-•, tr•r fs _'C.1;•r "S?. .r••1
44 9-fi `ti;: +M i :'�.G_• !L�i. ,Q1i. -{_ R� d .o '!" �=! 's+ --rA t3 f ��+ -3'
�`• �..� _ '>�'' f. U •►� ��• Qy • _ .r..a _ f • , i , i w... F-y_!''x. . �'' "�; �r•a
..I• !' " � i' ' '!'�+b: - • .Y' k -af{, � I - .•r� �7 ,;C kt, ,Fli,'"• : •. � •if��y,.,rxx�,L�: �. r,..+, ,.
.l r ,�1' f' � ( 1 ' t, �{ • •� r, . ii � f3�F•'+tt' r h;. Yti:'' �r"i.•�^ '��i: d'�C .0 t+ � G.�;. yr � - lt.`. -ale}:•�t ,r.,,>. r;^i.
f rr . •aL :. l :>r.' ; :d Ir i' ' g � irl, ,►.,,1• "J.
}}� H !e1 yy - � ;'1j : .N.: •f A' �: „�. 1 � �: r' n i, . rm.r" . ' r •• •:1, � 7 ,�.:.., t i+.' �'° It„ i tf .Yls
,t+ r'6iF• ' +{ ° ,S1 F;. 43 �,i.. !; ,w� _ e' !.'> ,+, t �9 I ,:�+' � t t'I Y�:IO''p r+ ^'� `I'� I `i Y f-tit h "`�".. } 4.,
! "° ` '� . I ' ' "a F.f' 1 t�'°I � r•,•}- � .i • � i � i y .Q} U �1 .L .�_ I I r
I' Q• _ I. ,. (• t �,i�• I GV- ,O 4JH �" s "t• q� 'r r l
4�u
'L-
.t•�t; ,,,, . + a : `, # . � 7 � 'r'41'' ak • . ;.tY 11 r 5: r t •SH �'.,. .#�' fir, i . 7•
d+iia ry �. t=.�.:.., I '1i 1. � ..i a.t d:' hN. '}•�
a •t" ry�r Z't'I.�•,�,t d r. � „�;. �kft ,l' n I �y .t, f .r •dr,v a,. ' � -
s '+ .� b r. a, r'F' :r' •. y , t1 j { 1 0.-. ' S/!`, -'�� -s r ".��.- i. '=•�+ .',tit.;.
`+� ' f ':�, ,t'Y';'i I F {(� dF „di e+'�! r .4 'y "i '"it _ r r h ' a �""''., r,i .. + 1. '�•,. ?r'�.'- �a" r. i•+ .i. �i.
+� , � ,. r. y .,S , x.:.i '� Flr.•'i;:+` , ii?.. _. #`d- "'!'• �� ..�' . 1 i'' �3 . °' � a,r}`r � �'. f .4'1� ' , , r; 3 i:lf-'- „,�z°.- v!;: , f ,. • t .�, : i v . - , ,ti,�e- r .>,..
^.+ _r.,4r .,.�nr L,{j "".—.: -Z�,, ,.y. 1 r � �, r .5E'y r-`` .• � .51 f { 'fit r'i �' t:� r� _ r ;i' - (_'.-! -:',, r*' i,;` �',r;�lt; 'r `�n !, ;t. „� iri,. yl a.. �: �t�i"'` VG� �.: ;„,�`C•.'iR",�,"d +',}. tf;Yt•. 1. 1, .! .,•�,. `nn i+,yk� �js "�''u,rS`�
3r 1 Y r• c r x 14 x-
r' k :'! .+'. t . n(,. � , "•y', .1�" ��t A `.$ - C.1
,;+_'c�.�•l r �. +- r.' 4�;. � 3.r, .t-
fi r s ( 'i..3t•'",11 r , +, r �.: Its "�.r .r• „ a.,.. r.� ; a, {% r "� .r :,t; �i"S,;t•, �, p .}fir .�,k•+ ,ir `, r?�" r �� tr�k ri � ''r?f�:�
s 1 r r x ' ! , -t : �f't'" , ,��r 7h k 'h�.,• ,�' r., -. r �.: `f,� S+ Si.. T`;k ,:f. & f..- : �.:. '�4, E d .,r, 'r�: .a y, �., r � _ '�.'i ' C
•:i° s, 5 r, :r8: :[. r �Y. :x :e• ,r,r' • <�- r 1° '4. ,f, 'S 4'.".6%K F ly,.
f"• .#� �•: "�, �?�;,. .Ls- ; �'. �, 1: �' :] # , '�R •G�' 1 ,.. ,�..,r�' ,.gyp. "':t''Lt .�*.
'r - d `x t ' *; ,1 �S rvr+ , •�+r, x: i�, x l J•• `,,� ,r + x, , x � � i
.- _� . }i' r"'r;,d;�,� rf��k j . �� � :'� ny ,'f?*.:f F S?t'.• k �h, '[ q.,,�;'azt � � '�'•f •! LL�. .'i [L�! ' � �i . : �;.:
"ir�''.•r �,.' .i.. F"S4rt,.�'i'^'%'�4 ., •zl. �' .� !� •� Pkd. € } m'.s� 'tvth'i•-; 'I` {, ,� {'F ,(• 't�iy�t, '}���,.:!t�.�,.¢.,
�i 4'. ti a't . .� �• 14WF ' 7 .tom .i � '` `$t- a �, Y��if�:. � ntt `�� r P h, , [i-y� -,r � � y , �' � �., r i�) �.r , ;, ,:t j, y,r. r••-�.,•-;`y�•r ; ygk� - e
I: ,L7 - _•4t�' t. 4 rU'[� :[9,p 'I' I `�A � s.:.�} r•-�. 1} _ _ .�,. .T' -..t ;x .YTq�.'�Er
tj $, ~ 1.� ,:: ` :1' r k (t1. ••-��,, V t -y' r. .� r _ .'r, .i 1,' - r. '.±' 1�!'Y' tt:,,,,ir .
��i� H:•. -
7 • 't w ! � :I . i,!.y•_ ,•f 1 , u' A s ,,,- c�,},�r •�t' r U'' r : Pi . L I .r:lpa #:v'h•i�.. r1N �
} , �• _ +:' ,� rrj'
,•. i3 � Ar, t r r �. "; t �� r '• � t + �;: n� ,. u � ; ." .:f • , ;s- .. '� '�,�i.. .
,� '+?!1 � �`i, f-s+ '� i l.. ,,�w' F� i,� �+{ i.z y.. -der..{{ t .' :t. s` 4 ' '�fZ��a.• � i a
r .je,k ': r fII,�A,, G - ,�+"£ I r� (r -; ! I r - t�.' , ' i t , t q" •:"-.
EE s j•�.. i � r• t •'�` I i. {

_ M Thrust W for
2: Factors .'for.; Calculating-
Elbows and Tees . _ r
o T 41;r� 0.70 -
bows• _
yA
E� • l-".`-.I� f 1,.���-
r .1
.. �GOo, � 00 _
45
r -d T di fferent say 1' types ;
Table 3M'give`sihe��sAfe'-, bear��ng, load�for � r
- - Table _3. Safe Bearing"Load:
�� `
..Sol l
- } �.i:ry-F� 'ice': -C -''1 ! - I T -- _ — ._—•�-. -- _ � ___ _
Mulch,�peat. and similar
�t �° -soft Cl ay - ..
—•..f '.,...tr-w_ r...,ak.. _T ..: �.�i.:- _ -- _ .G:...i.. _ ..�
(J'`aand, aiidr_avelr 300i? �� k, r
a'nd �gravel:�cemented
- - -� = -- _ - -4000 -
shale i0,000
<< 77 -
a� f ` '
ET
2 Ids 5f Thrust -(Table. l� & Table �-2) ..
bloc �area�ft'.'} -soilBaring strengt a e 3}'
scE -
-zt
�° rt in ;pi acing:concrei;e rust:'blacks;=checkiwi=t - e-manu ac �rer...,o the
- .. pipe=being u4ed,-;ty ensure-dat rt e coix�ct=saze_thr_usi_blocks are
-beip •used':: � --- .':. - - • - -- . - _ .,�. _
�- -There are a ;number `af;'machines that. -can -be used to prepare,. the: _
t ;. .__. -
.-. trench for.:PVC.plastzc; pipe.. '-Soil types, moisture content, de of- n -
- tr_ench_required and. type: and diame-ter'.of, pipe must be considered.
Generally chain"ruches, wheel=trenches;-backhoes:,, ar-vbratig plows
_'. .
' will; be- used for 'trench preparation. - -Thd vibratin'9% plow can only be:: -
` used for solvent .�wel d- .PVC pipe _and, generally' is limited to the Ismala er,- -
' a l�ride`r=mast- �ndi.ti�ns-the_cha n- trencher or:.,irheel
-. xhT diameter ,of p�P .,
trencher. will-, w.faster ,than the backhoe. there wide trenc[�es, for ,alarge
pipe are' required, the backhoe::,:wi1l be most satisfactory. If soil
conditions permi:i: :Yong.:stretches of:open trench will expedite p�pef s
� installation: However:;;if rain�is :forecast -the -pipe-should--.be:nsta3_ted__ _
2 4E� — p the line aty obstructions, .
.and_the trench backf lledr To avoid spar turns in ,
of cpr.vature of the pipe ,
; '�` trencfies` should e., curved wz th 1 r% l t�i is F _
"t' - �•k
_ ' � _ - ; _. - .vim r. :,''`� a ` � f _� P'= - .- -- - `� 3s •��,J�c.., -
T

ANIMAL FACILITY ANNUAL CERTIFICATION FORM
Certificate of Coverage or Permit Number A j-j z j Q g County _ Year 2003
Facility Name (as shown on Certificate of Coverage or Permit) ?Ld,!i dn4 A-0 V P_ N Ugat� 4 c;�
Operator in Charge for this Facility Danr)r,.l Korrwoa u r. Certification #
Land application of animal waste as allowed by the above permit occurred during the past calendar year
YES NO. If NO, skip Part I and Part 11 and proceed to the certification. Also, if animal waste
was generated but not land applied, please attach an explanation on how the animal waste was handled.
Part!: Facility Information: ��
1. Total number of application Fields ❑ or Pulls '(please check the appropriate box) in the Certified Animal
Waste Management Plan (CAWMP):
g4.a
Total Useable Acres approved in the CAWMP
2. Total number of Fields ❑ or Pulls E� lease check the appropriate box) on which land application
occurred during the year: 15? _ Total Acres on which waste was applied qc�-
3. Total pounds of Plant Available Nitrogen (PAN) applied during the year for all application sites:
4. Total pounds of Plant Available Nitrogen (PAN) allowed to be land applied annually by the CAWMP and
the permit: 11 9
5. Estimated amount of total manure, litter and process wastewater sold or given to other persons and taken
off site during the vear 0 _ tons D or gallons u (please check the appropriate box)
6. Annual average number of animals by type at this facility during the previous year:
Y VJ(N
2o04
7. Largest and smallest number of animals by type at this facility at any one time during the previous year:
Largest
Smallest
(These numbers are for informational purposes only since the only permit limit on the number of animals
at the facility is the annual average numbers)
8. Facility's Integrator if applicable: _ - .-ffltb �
Part 13: Facility Status:
IF THE ANSWER TO ANY STATEMENT BELOW IS "?NO", PLEASE PROVIDE A WRITTEN
DESCRIPTION AS TO WHY THE FACILITY WAS NOT COMPLIANT, THE DATES OF AT
NON
COMPLIANCE, AND EXPLAIN CORRECTIVE ACTION TAKEN OR PROPOSED TO.BE TAKEN TO
BRING THIS FACILITY BACK INTO COMPLIANCE.
1. Onlv animal waste generated at this facility was applied to tl gi C1 gi#es&ring I,Xes [J- No
the past calendar year.
MAR 0 2 Z004
AFACF 3-14-03 l WA6j F Cll}ALV 51ianc 1.
Non•Discha , romp

2. The facility was operated in such a way that there was no direct runoff of waste from 'Yes [I No
the facility (including the houses, lagoons/storage ponds and the application sites) during
the past calendar year.
3. There was no discharge of waste to surface water from this facility during the past 'Yes ❑ No
calendar year. .
4. There was no freeboard violation in any lagoons or storage ponds at this facility during �es Ell No
the past calendar year_ �/
5. There was no PAN application to any fields or crops at this facility greater than thee/ Yes E, No
levels specified in this facility's CAWMP during the past calendar year_
6. All land application equipment was calibrated at least once during the past calendar year. P" es ❑ No
7_ Sludge accumulation in all lagoons did not exceed the volume for which the lagoon Ell Yes i �� No p/19-
was designed or reduce the lagoon's minimum treatment volump to less than the volume
for which the lagoon w-as designed. 5ppe. V Er i 1�
8. A copy of the Annual Sludge Survey Fbtm for &is facility is attached to this Certification. J Yes r11 No n7
9. Annual soils analysis were performed on each field receiving animal waste during the
EP-les C No
past calendar year.
10_ Soil pH was maintained as specified in the permit during the past calendar Year?
['Yes �J No
11. All required monitoring and reporting was performed in accordance with the facility's
!?Yes ❑ No
permit during the past calendar year.
12. All operations and maintenance requirements in the permit were complied with during
Yes ID No
the past calendar year or, in the case of a deviation, prior authorization was received
from the Division of Water Quality.
13. Crops as specified in the CAV MW were maintained during the past calendar year on all
Rr Yes 0 No
sites receiving animal waste and the crops grown were removed in accordance with
the facility's permit.
14. All buffer requirements as specified on the permit and the CAWNIP for this facility were
iFZ- s E] No
maintained during each application of animal waste during the past calendar year.
" I certify under penalty of law that this document and all attachments were prepared under my direction or
supervision in accordance with a system designed to assure that qualified personnel properly gather and
evaluate the information submitted. Based on my inquiry of the person or persons who manage the system, or
those persons directly responsible for gathering the information, the information submitted is, to the best of
my knowledge and belief, true, accurate, and complete. I am aware that there are significant penalties for
submitting false information, including the possibility of fines and imprisonment for knowing violations."
(,j e 11 N e a oo e,r e Y ado r
rznittee Name and itle or print)
a
Signature of Permittee Date
Signature of Operator in Charge Date
(if different from Permittee)

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Komegay Brothers Inc.
Pleasant Grove Nursery 1 &2
221 Scotts Store Rd
Mt. Olive NC 28365
Dear Kornegay Brothers Inc.:
�4�
/ 0 •
NCDENR
NORTH CAROLINA DEPARTMENT OR
ENVIRONMENT ANC) NATURAL RESOURCES
December 8, 1999
Subject: Conditional Approval
Animal Waste Management System
Facility Number 31-287
Duplin County
Our records indicate that. your facility was conditionally certified in order to fulfill the requirements of
completion of your Certified Animal Waste Management Plan Certification. This letter is to inform you of your
unresolved conditional approval status. Any facility receiving a conditional approval must notify Division of Water
Quality (DWQ) in writing within 15 days after the date that the work needed to resolve the conditional certification
has been completed. Any failure to notify DWQ as required, subjects the owner to an enforcement action. As of
December 7, 1999, we have no record of any information from you, advising us of the status of your conditional
approval. Therefore, please fill out the attached form and have your technical specialist and landowner sign the form
in the appropriate areas.
The completed form must be submitted to this office on or before 45 days of receipt of this letter. Please be
advised that nothing in this letter should be taken as removing from you the responsibility or liability for failure to
provide DWQ with proper notification of your conditional certification status or possible failure to comply with the
requirement to develop and implement a certified animal waste management plan by December 31, 1997.
If you have any questions regarding this letter, please do not hesitate to contact me at [phone]
extension 571.
Sincerely, A7>�
' •�pl� /�
Sonya L. Avant
Environmental Engineer
cc: Wilmington Regional Office
Dupiin County Soil and Water Conservation District
Facility File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper
1�

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
October 17, 1997
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Kornegay Brothers Inc.
221 Scotts Store Rd
Mt. Olive NC 28365
A14
C)EHNR
Subject: Pleasant Grove Nursery 1 &2
COC No. AWS310287
Duplin County
Dear Komegay Brothers Inc.:
The subject facility was issued a Certificate of Coverage (COC) on 4/28/97 authorizing the
operation of the animal waste collection, treatment, storage, and land application system in accordance
with General Permit No. AWG 100000. On Aug. 27, 1997 Governor Hunt signed into law the Clean
Water Responsibility Act. The Clean Water Responsibility Act included several changes to the Swine
Faun Siting Act (Siting Act) including the requirement that all set back distances be: met for any swine
lagoon or swine house for which construction commences on or after the effective date of the- Clean Water
Responsibility Act (Aug. 27, 1997). Before the Siting Act was amended, it required the set back distances
be met at the time the swine house or lagoon was sited. The change in siting requirements may. apply to
your farm since construction may not have commenced by the effective -date of the Clean - Water.
Responsibility Act. '
Your farm was permitted prior to the effective date of the Clean Water Responsibility Act;
therefore, you meet one of the exceptions to the moratorium. However, the farm must be re-evaluated
and, if necessary, re -designed to meet the new requirements of the Siting Act to remain covered under the
General Permit. Within 15 days of the date of this letter, you are requested to submit, notification to the
Division of Water Quality whether the farm was under construction on or before Aug. 27, 1997.
If the farm was not under construction on or before Aug. 27, 1997, then a revised Certified Animal
Waste Management Plan must be submitted to reflect the new siting requirements. Construction not in
compliance with the Siting Act is a violation of State Statutes and the General Permit.
If you have any questions or comments concerning this matter, please contact me at (919) 733-
5083 extension 540.
Sincerely
f
Kirri-H-Olson,,
Non -discharge Permitting Unit
cc: Wilmington Regional Office, Water Quality Section
Permit File
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

State of North Carolina
Department of Environment . RECEIVED
and Natural Resources
Division of Water Quality JUL 0 2 1998
James B. Hunt, Jr., Governor 1EK
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
June 26, 1998
Kornegay Brothers Inc.
Pleasant Grove Nursery 1 &2
221 Scotts Store Rd
Mt. Olive NC 28365
ILF - �AFA
IT 00
NCDENR
NOFrrH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Reissuance of Certificate of Coverage
No.AWS310287
Pleasant Grove Nursery 1 &2
Swine Waste Collection, Treatment, Storage and
Application System
Duplin County
Dear Kornegay Brothers Inc.:
The Division of Water Quality modified the Swine Waste Operation General Permit originally issued to
this facility on April 28, 1997. In accordance with the issuance of the revised General Permit, we are
forwarding this Certificate of Coverage (COC) to Kornegay Brothers Inc., authorizing the operation of
the subject animal waste collection, treatment, storage and land application system in accordance with
General Permit AWG100000. This approval shall consist of the operation of this system including, but
not limited to, the management of animal waste from the Pleasant Grove Nursery 1 &2, located in Duplin
County, with an animal capacity of no greater than 5200 Wean to Feeder and the application to land as
specified in the Certified Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003, and shall hereby void
COC No AWS310287 dated April 28, 1997. The COC shall hereby incorporate by reference any
specific conditions of the previous COC issued to this facility. The purpose of this COC is to allow
coverage under the revised General Permit. Please review the revised General Permit (enclosed) and pay
particular attention to Condition 1I.10 regarding tree removal from lagoon embankments, Condition I1I.1
regarding inspection frequency of the waste treatment, storage and collection system and Condition 111.6
regarding notification requirements for system failures, spills and emergencies. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations
as specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the
General Permit or the CAWMP may result in the revocation of this COC, or penalties in accordance
with NCGS 143-215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive
relief.
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Certificate of Coverage AWS310287
Pleasant Grove Nursery 1&2'
Page 2.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This
request shall be made within 30 days of notification by the Division.
This COC is not automatically transferable. A name/ownership change application must be
submitted to the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the
right to apply for an individual non -discharge permit by contacting the engineer listed below for
information on this process. Unless such a request is made within 30 days, this COC shall be final and
binding.
The subject farm is located in the Wilmington Regional Office. The Regional Office Water
Quality Staff may be reached at [phone]. If you need additional information concerning this
COC or the General Permit, please contact Sue Homewood at [phone] ext. 502.
Sincerely,
for A. Preston Howard, Jr., P.E.
cc: (Certificate of Coverage only for all cc's)
Duplin County Health Department
Wilmington Regional Office, Water Quality Section
Duplin County Soil and Water Conservation District
Permit File

Kornegay Brothers 1 �'�- �[ VE+
221 Scotts Store Road JUN 1
Mount Olive, NC 28365 0 19%
May 26, 1998
RE: Pleasant Grove Nursery 1 &21Fa 'ty #31-287
Mr. Brian Wrenn
NCDENR
127 Cardinal Drive
Wilmington, NC 28405
Dear Mr. Wrenn:
This Ietter is in response to your letter dated May 15, 1998.
Immediately after I received the Notice of Deficiency, I contacted my local Soil &
Water Conservation Office for assistance.
I have addressed the additional information you requested. Please see the attached
forms. If you have any questions or need additional information, please feel free to
contact me at the above address.
S'ncereI ,
Robert Kornegay
Kornegay Brothers

State of North Carolina ` •
Department of Environment JUN 10
and Natural Resources
Wilmington Regional Office NCODENR
James B. Hunt, Jr., Governor NcRrH CAROLMA DEPARTMENT OF
EMARONMENT AND NATURAL RESOURCES
Wayne McDevitt, Secretary
Division of Water Quality
May 15, 1998
Certified Mail # Z 312 646 290
Return Receipt Requested
Mr. Robert Kornegay
Kornegay Brothers, Inc.
Pleasant Grove Nursery 1 and 2
221 Scotts Store Road
Mt. Olive, North Carolina 28365
Subject: NOTICE OF DEFICIENCY
Pleasant Grove Nursery 1 and 2
Facility Number: 31-287
Duplin County
Dear Mr:-Kornegay:
On May 15;=..1998, staff from the Wilmington Regional Office of the Division of Water
Quality inspecte#.your-animal operation and the lagoon(s) serving this operation. It was observed
that tobacco is planted in a spray field designated -by _the _Certified.Animal Waste. Management. Plan —
(CAWMP) for atcarnlwheat/soybean rotation �' (CWrox; tls� reS�Ql �n C`IS,Ia �
S<�,.re° !�wsa �'i'i �.TLR'�j_ J�, r., % f r s�t.i;?°y
AII'crops.t`o0+be,p3anted should be listed.for each spray.field in:tne'Certified Animal Waste
Mani ement Plan.' on efforts.ta.ve' etate.la oon #2.shauld be continued. The lagoon
clesi `iiaformatiol'-for lagoo>i;#�1�s ould,b the WMP. The a p lion dates for the wheat j
c p sliould r e _- t ' n servzc�e company, local MRCS or Soil
anWater Dstric -office for any assistance they may be able to provide to correct the situation.
To remain a deemed permitted facility, you- must notify this office in writing within
fourteen (14) days of the receipt of this notice, what actions will be taken to comply with your waste
management plan. Failure to do so may result in the. facility losing it's deemed permitted status,
requiring it to obtain an individual non discharge permit.
127 North Cardinal Dr., Wilmington, North Carolina 28405 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

{
' � f
�• -.•T� I
Mr. Robert Kornegay
May 15, 1998
Page 2.
Please be aware it is a violation of North Carolina General Statutes to discharge wastewater
to the surface waters of the State without a permit. The Department of Environment, Health and
Natural Resources has the authority to levy a civil penalty of not more than $10,000 per day per
violation.
When the required corrective actions are complete, please notify this office in writing at
the address below. If you have any questions concerning this matter, please call David Holsinger
or Brian Wrenn at 910-395-3900.
Sincerely,
Brian L. Wrenn
T Environmental Specialist-
.
cc: HaroldJones, County Soil and Water Conservation
Sandra Weitzel, NC Division of Soil and Water Conservation
jDr..,Garth Boyd; Murphy Family Farms
Operations Branch. - . • .
Wilmington Files
S:IWQSlBRIANWii7$F'98U3UP�Wy31287DEF
7-A

ANIMAL WASTE UTILIZATION PLAN
Producer: ROSERT KORNEGAY
Location: 221 SCOTTS STORE ROAD
MOUNT OLIVE NC 28365
Telephone: [phone]
Type Operation: Existing Wean to Feeder Swine
Number of Animals: 5200.00 pigs
(Design Capacity)
STORAGE STRUCTURE: Anaerobic Waste Treatment Lagoon
APPLICATION METHOD: Irrigation -.-
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops
in the fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply
more.nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall be applied to land eroding at less than
5 tons per acre per year. waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on saturated soils, when it is raining,
or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed
under DWQ regulations.
J iS
Parrs.

ANIMAL WASTE UTILIZATION PLAN
TABLE l: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
----
or
-------
APPLY
RESID.
APPLIC
METH
N
TIME
3226
1
AUB
C
75'
73.75
20
12
885
I
MAR-JUN
3226 1-1 IAUB I W 145 190 1 112 11080 AR
3226 1 JAUB DSB 118 172 112 �864
I JUN-SEPT
15
END
z
TOTAL12829
- Indicates that this field is being overseeded (i.e. interplanted)
or winter annuals follow summer annuals.
NOTE: The applicator is cautioned that P and K may be over applied
while meeting the N requirements. In the future, regulations may
require farmers in some parts of North Carolina to have a
nutrient management plan that addresses all.nutrients. This plan
only addresses nitrogen.
Page: 3

ANIMAL WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
See required specification 2.)
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
-------
APPLY
RESID.
APPLIC
METH
N
TIME
4092
2
AUB
C
75
73.75
20
2$
2065
_-
MAR-JUN
4092
-2
`IAUB
IW
145
190 1
128
12520
OCTMAR
4092
"2
DS$
JAUB
118
172 1
128
12016
JUN-SEPT
15
4092
3
AUB
6.6
1
IC
175
173.75 120
148G.75.
MAR -JUN
4092
3
AIM
W
145
190 1
16.G
1594
OCT-MAR
4092
DSB
1-3
JAUB
118
172 1
16.6
1475.2
JUN-SEPT
15
4092
4
1AU11
IC
175 173.75
120 120.8
11534
MAR-JUN
4092
W
45
1-4
JAUB
190
1
1
120.8
11872
OCT-MAR
4092
DSB
1-4
JAUD
118 172
1
120.8
11497.6
JUN-SEPT
15
END
TOTAL113060.5
Indicates that this field is being overseeded (i.e. interplanted) or
winter annuals follow summer annuals.
Page: 4

ANIMAL WASTE UTILIZATION PLAN
** Acreage figures may exceed total acreage in fields due to
overseeding.
* lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and 2 above:
CROP CODE
CROP
UNITS
PER UNIT
C
K
CORN
�
BUSHELS
1.25
DSB
DOUBLE CROPPED SOYBEANS
BUSHELS
4
W
WHEAT
BUSHELS
2
TABLE 1
TABLE 2
TOTAL
**
TOTALS FROM TABLES 1 AND 2
WETTABLE
_ACRES
12
LBS AW N USED
2829
55.4
13060.55
67.4
15889.55
* BALANCE
--10897.55
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.
Page: 5

ANIMAL WASTE UTILIZATION PLAN
r�
ensure that the spreader equipment is operated properly to apply the
correct rates to the acres shown in Tables 1 and 2. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may
make this plan invalid.
Call your technical specialist after you receive the waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate prior to applying the waste.
NARRATIVE OF OPERATION
Tract #3226, Field #1, is in a rotation. This field has approximately 38 acres.
Only a small portion of this field is needed for the Waste Utilization Plan.
(SEE PAGE 3) The remainder of this field will be in other crops such as tobacco,
sweet potatoes etc. These other crops will not be used for waste utilization.
i
Tract #4092, Field #1, will also contain other crops such as tobacco, sweet
potatoes etc. in addition Eo corn/soybean/wheat. These other crops are not
required for waste utilization. Mr. Rornegay may spray on corn/soybean/wheat in
this field 1 if crop needs nitrogen on an as needed basis, but this is not
required in waste utilization plan. If spraying on this acreage, Mr. Rornegay
will use rates for corn/soybean/wheat as specified in the plan.
M
Page: 8

Mr. Robert Kornegay
May 15, 1998
Page 2.
Please be aware it is a violation of North Carolina General Statutes to discharge wastewater
to the surface waters of the State without a permit. The Department of Environment, Health and
Natural Resources has the authority to levy a civil penalty of not more than $10,000 per day per.
violation.
When the required corrective actions are complete, please notify this office in writing at
the address below. If you have any questions concerning this matter, please call David Holsinger
or Brian Wrenn at 910-395--3900.
Sincerely,
Brian L. Wrenn
Environmental Specialist
cc: Harold Jones, County Soil and Water Conservation
Sandra Weitzel, NC Division of Soil and Water Conservation
Dr. Garth Boyd, Murphy Family Farms
Operations Branch
Wilmington Files
S:1 WQSIBRIANWIDEF98LD UPLIM31-28Z DEF

Revised April 20, 1999
.JUSTIFICATION & DOCUMENTATION FOR MANDATORY WA DETERMINATION
Facility Numb r
Farm Name: _
On -Site Representative: w„ Cd
lnspectorlReviewer's Name:>
Date of site visit: 6(g_*9
Date of most recent WUP: l0 1
Annual farm PAN deficit: pounds
Operation is flagged for a wettable
acre determination due to failure of
Part !1 eligibility items) Ft F2 F3 F4
J Operation not required to secure WA
determination at this time based on
exemption (5 E2 E3 E4
Operation pended for wettable acre
determination based on P1 P2 P3
Irrigation Systems) - circle #: 1�. harts -hose traveler, 2. center --pivot system; 3. linear -move system;
4. stationary sprinkler system wlpermanent pipe; 5. stationary sprinkler system w/portable pipe;
6. stationary gun system wlpermanent pipe; 7. stationary gun system w/portable pipe
PART I. WA Determination Exemptions (Eligibility failure, Part 11, overrides Part I exemption.)
V E1 Adequate irrigation design, including map depicting wettable acres, is complete
and signed by an I or PE.
E2 Adequate D, and D21D3 irrigation operating parameter sheets, including map
depicting wettable acres, is complete and signed by an I or PE.
E3 Adequate D, irrigation operating parameter sheet, including map depicting
wettable acres, is complete and signed by a WUP.
E4 75% rule exemption as verified in Part ill. (NOTE:75 % exemption cannot be
applied to farms that fail the eligibility checklist in Part 11. Complete eligibility
checklist, Part 11- F1 F2 F3, before completing computational table in Part 111).
PART I1.75% Rule .Eligibility Checklist and Documentation of WA Determination
Requirements. WA Determination required .because. operation fails one of the eligibility -
requirements listed -below:
F1 Lack .ofacreage_whichTesultedin:overmpplicationmf--wastewater (PAN) on:spray,
field(s) accordinafofarm'sdasttwo-rears:Df-tmg2tion�ecords.
F2 Unclear, -illegible, -or lack of information/map.
F3 Obvious -field -limitations-(numerous:.ditches;failurefo_deductTequired ....
buff:erlsetbackzcreaae;-or25%:ofTotal=acreageadentified_in`CAWMP.-includes _
small 'JrreguIady-shaped.fields - fields:lessfhan-5-acresfor#ravelers-oHess-than
2 acresfor.-stationarysprinklers).
F4 WA determination required because CAWMP credits f eld(s)'s acreage -in excess
of 75% of the respective field's total acreage as noted in table in Part III.

Revised April 20, l 999
Facility Number-..
Part III. Field by Field Determination of 75% Exemption Rule for WA Determination
TRACT
FIELD
TYPE OF
TOTAL
CAWMP
FIELD
COMMENTS'
NUMBER
NUMBER',z 1
IRRIGATION
I
ACRES
ACRES
%
SYSTEM
and type of irrigation -system. If pulls, etc. cross more than one field, inspector/reviewer will have to combine fields to
calculate 75% field by field determination for exemption; otherwise operation w_M be subject to WA determination.
FIELD NUMBERZ - must be clearly delineated on map.
COMMENTS' - back-up fields with CAWMP acreage.exceeding75% of its total .acres and having Teceived less than 50%
of its annual PAN as documented in the farm's previous -two years' (1997 & 199B) of irrigation Tecords; cannot serve -as -the
sole basis -for requiring a WA Deter ina#ion: hack-upfields-must be noted in the -comment section and must be accessible
by irrigation system.
Part IV. Pending WA Determinations -
Pi Plan Jacks. following -information:
P2 Plan -revision may_satisfy75% rule based on adequate overall PAN deficit-andby
adjusting all field -acreage -to below 75% use rate
P3 Other (ierin process of installing new irrigation system):

Site Requires Immediate Attention:
Facility No. ° I -A'7
. DIVISION OF ENVIRONMENTAL MANAGEMENT
ANIMAL FEEDLOT OPERATIONS SITE VISITATION RECORD
DATE: _7' — a k , 1995
Time: _ L�� o b
Farah Name/Own(
Mailing Address:
County: jj joJ _
Integrator: Phone:
On Site Representative: Phone: 46tr)-P_A — 919
Physical Address/Location: - f�' _ - t -
Type of Operation: Swine J_ Poultry Cattle grLT7
Design Capacity: Number of Animals on Site: 7 f
DEM Certification Number: ACE DEM Certification Number: ACNEW
Latitude: , " , Longitude: _ OE' Elevation: Feet
Circle Yes or No
Does the Animal Waste Lagoon have sufficient freeboard of 1 Foot + 25 year 24 hour storm event
(approximately 1 Foot + 7 inches) 10 or No Actual Freeboard: _2Ft. Inches
Was any seepage observed from the lagoon(s)? Yes or P@ Was any erosion observed? Yes 0(9
Is adequate land available for spray? es or No Is the cover crop adequate? Yes or No
Crop(s) being utilized: a o
Does the facility meet SCS minimum setback criteria? 200 Feet from Dwellings. es)or No
100 Feet from Wells? e or No
Is the animal waste stockpiled within 100 Feet of USGS Blue Line Stream? Yes or&
Is animal waste land applied or spray irrigated within 25 Feet of a USGS Map Blue Line? Yes o hi'
Is animal waste discharged into waters of the state by roan -made ditch, flushing system, or other
similar man-made devices? Yes 10 If Yes, Please Explain.
Does the facility maintain adequate waste management records (volumes of manure, land applied,
spray irrigated on specific acreage with cover crop)? Yes or4T '7
Additional Comments:
/_� '1_2 el il\
In pector Name
Signature
cc: Facility Assessment Unit Use Attachments if Needed.

State of North Carolina '
Department of Environment, ECEIVED
Health and Natural Resources ' APR����
Division of Water Quality
II�C.
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
A. Preston Howard, Jr., P.E., Director
April 28, 1997
Robert Kornegay
Pleasant Grove Nursery 1 &2
221 Scotts Store Rd
Mt. Olive. NC 28365
4 • •
�T
CaEHNF 1
Subject- Certificate of Coverage No. AWS310287
Pleasant Grove Nursery 1 &2
Swine Waste Collection, Treatment. Storage
and Application System
Duplin County
Dear Robert Kornegay:
In accordance with your application received on April 16, 1997, we are forwarding this Certificate
of Coverage (COC) to Farm No. 31-287, authorizing the operation of an animal waste collection,
treatment, storage and land application system in accordance with the State's General Permit (attached).
This approval shall consist of the operation of this system including, but not limited to, the management of
animal waste from the Pleasant Grove Nursery 1 &2 Farm with an animal capacity of no greater than 5200
Wean to Feeder and the application to 67.4 acres of land. The facility shall be located in Duplin County
with no discharge of wastes to the surface waters.
The COC shall be effective from the date of issuance until December 31, 2001. Pursuant to this
COC, you are authorized and required to operate the system in conformity with the conditions and
limitations as specified in the General Permit, the facility's Certified Animal Waste Management Plan
(CAWMP), and this COC. An adequate system for collecting and maintaining the required monitoring
data and operational information must be established for this farm. Any increase in waste production
greater than the certified design capacity or increase in number of stocked animals above the ri'umber
authorized by this COC will require a modification to the CAWMP and this COC and shall be completed
prior to actual increase in either wastewater flow or number of animals.
In accordance with General Statue 143-215.1OC, Animal Waste Management Plans shal-include
the following components:
- A checklist of odor sources and best management practices to minimize these sources.
- A checklist of insect sources and best management practices to minimize these sources.
- Provisions set forth for acceptable methods of disposing of mortalities.
- Provisions regarding emergency action plans.
Your Certified Animal Waste Management Plan must include the above elements. Documentation
of the certification must be available to inspectors onsite.
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Please be advised that any violation: of the terins•and'conditions specified in this COC, the General
Permit or the CAWMP may result in the revocation of this COC.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This
request shall be made within 30 days of notification by the Division.
This COC is not automatically transferable. A name/ownership change application must be
submitted to the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the
right to apply for an individual non -discharge permit by contacting the engineer listed below for
information on this process. Unless such a request is made within 30 days, this COC shall be final and
binding.
The subject farm is located in the Wilmington Regional Office. The Regional Office Water Quality
Staff may be reached at [phone]. If you need additional information concerning this COC or the
General Permit, please contact Mike Lewandowski at [phone] ext. 362.
Sincerely,
Preston H ard, Jr., P.E.
cc: (Certificate of Coverage only for all cc's)
Duplin County Health Department
Vyilmington-Regional-Office,—Water-Quality Sectign
Duplin County Soil and Water Conservation District
Facilities Assessment Unit
Central Files

State of North Carolina
Department of Environment,
Health and Natural Resources
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
November 13, 1996
Robert Komegay
Pleasant Grove Nursery
221 Scotts Store Rd
Mt. Olive NC 28365
SUBJECT: Operator In Charge Designation
Facility: Pleasant Grove Nursery
Facility ID#: 31-287
Duplin County
Dear Mr. Kornegay:
Senate Bill 1217, An Act to Implement Recommendations of the Blue Ribbon Study
Commission on Agricultural Waste, enacted by the 1996 North Carolina General Assembly,
requires a certified operator for each animal waste management system that serves 250 or more
swine by January 1, 1997. The owner of each animal waste management system must submit a
designation form to the Technical Assistance and Certification Group which designates an
Operator in Charge and is countersigned by the certified operator. The enclosed form must be
submitted by January 1, 1997 for all facilities in operation as of that date. Failure to designate a
certified operator for your animal waste management system is a violation of 15A NCAC 2H
.0224 and may result in the assessment of a civil penalty.
If you have questions concerning operator training or examinations for certification, please
contact your local North Carolina Cooperative Extension Service agent or our office.
Examinations have been offered on an on -going basis in many counties throughout the state for
the past several months and will continue to be offered through December 31, 1996.
Thank you for your cooperation. If you have any questions concerning this requirement please
call Beth Buffington or Barry Huneycutt of our staff at 919/733-0026.
Sincerel
A. Preston Howard, Jr., P.E., Director
Division of Water Quality
Enclosure
cc: Wilmington Regional Office
Water Quality Files -
P.O. Box 27687. �.���
Raleigh, North Carolina 2761 1-7687 ��C An Equal Opportunity/Affirmative Action Employer
Voice 919-715-4100 - 500% recycled/look post -consumer paper

. %4 - L
REGISTRATION FORM FOR ANIMAL FEEDLOT OPERATIONS
Department of Environment, Health and Natural Resour
Division of Environmental Management
Water Quality Section r UP4�Z
. `*C
If the animal waste management system for your feedlot ape i0rr411"IN
is designed to serve more than or equal to 100 head of catt !1 75 C�
horses, 250 swine, 1,000 sheep, or 30,000 birds that are sery lS 8�9
by a liquid waste system, then this form must be filled out and
mailed by December 31, 1993 pursuant to 15A NCAC 2H.0217 (c) in
order to be deemed permitted by DEM. Please print clearly,
Farm Name: jL�2:i C,Ic ve­
Mailing Address: Z.Z�
C& �.
County: L4 ED-�
Owner(s) Name:
Manager(s) Name:
Lessee Name:
Phone # _q R:�:_6fst - D:i 14
Farm Location (Be as specific as possible: road names,___.__
direction, milepost, etc.) : From Kenansville, take - NC 11/903 N 9. 0
miles, turn Lt. onto SR 1501 (Woodland Ch—
i Rd) just past Microwave Tower, go 0.8
�i�--- mile and bear Lt. onto SR 1500 (Tram Rd),�—�
go to Scotts Store, turn Rt. onto SR 1521
(Scotts Store Rd) and go 0.4 mile to farm
entrance on Lt. (TT=36 min._; TD=29_miles)
Latitude/Longitude if known: QBSP #: = �Aal
Design capacity of animal waste management system (Number and
type of confined animal (s) : 24an
Average animal population on the farm (Number. -and type of
animal (s) raised) : ` rsc� �, 5 �wec.nlen�; -ko -�e
Year Production Began: 177 3 ASCS Tract No.: aC _ 5 a a,6
Type of Waste Management System Used:
Acres Available for Land A4VIicationIO Waste: -
Owner(s) Signatures): _..-�. -- --Date:--
_ . Date
3 1 - -�$-+

State of North Carolina
Department of Environment,
Health and Natural, Resources
Division of Environmental Management
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
A. Preston Howard, Jr., P.E:, Director
March 23, 1994
Robert Komegay
221 Scotts Store Rd.
Mt. Olive NC 28365
Dear Mr, Kornegay:
This is to inform you that your completed registration form required by the recently
modified nondischarge rule has been received by the Division of Environmental Management
(DEM), Water Quality Section.
On December 10, 1992 the Environmental Management Commission adopted a water
quality rule which governs animal waste management systems. The goal of the rule is for animal
operations to be managed such that animal waste is not discharged to surface waters of the state.
The rule allows animal waste systems to be "deemed permitted" if certain minimum criteria are
met (15A NCAC 2H .0217). By submitting this registration you have met one of the criteria for
being deemed permitted.
We would like to remind you that existing feedlots which meet the size thresholds listed
in the rule, and any new or expanded feedlots constructed between February 1, 1993 and
December 31, 1993 must submit a signed certification form (copy enclosed) to DEM by
December 31, 1997. New or expanded feedlots constructed after December 31, 1993 must
obtain signed certification bCforC animalsr k n the farm. Certification of an
approved animal waste management plan can be obtained after the Soil and Water Conservation
Commission adopts rules later this year.
We appreciate you providing us with this information. If you have any question about
the new nondischarge rule, please contact David Harding at [phone].
enc:
Sincerely,
/let Steve Tedder, Chief
Water Quality Section-
P.O. Box 29535. Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer .50% recycled/ 10% post -consumer paper

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
Kornegay Brothers Inc.
Pleasant Grove Nursery 1 &2
221 Scotts Store Rd
Mt. Olive NC 28365
Dear Kornegay Brothers Inc.:
417
•
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
December 30, 1999
Subject: Fertilizer Application Recordkeeping
Animal Waste Management System
Facility Number 31-287
Duplin County
This letter is being sent to clarify the recordkeeping requirement for Plant Available Nitrogen (PAN)
application on fields that are part of your Certified Animal Waste Management Plan.
In order to show that the agronomic loading rates for the crops being grown are not being exceeded, you
must keep records of all sources of nitrogen that are being added to these sites. This would include nitrogen
from all types of animal waste as well as municipal and industrial sludges/residuals, and commercial fertilizers.
Beginning January 1, 2000, all nitrogen sources applied to land receiving animal waste are required to
be kept on the appropriate recordkeeping forms (i.e. IRRI, IRR2, DRY1, DRY2, DRY3, SLUR1, SLUR2,
SLD1, and SLD2) and maintained in the facility records for review. The Division of Water Quality (DWQ)
compliance inspectors and Division of Soil and Water operation reviewers will review all recordkeeping during
routine inspections. Facilities not documenting all sources of nitrogen application will be subject to an
appropriate enforcement action.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Ms. Sonya Avant of the
DWQ staff at [phone] ext. 571.
Sincerely,
Kerr T. Stevens, Director
Division of Water Quality
cc: Wilmington Regional Office
Duplin County Soil and Water Conservation District
Facility File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

L�r
L � up ra
r
F AM I L Y F A R M S
October 28, 1997
North Carolina Dept. of Environment, Health & Natural Resources
Division of Water Quality
Water Quality Section
Permits and Engineering Unit
P.O. Box 29535
Raleigh, NC 27626-0535
Attn: Kim H. Colson, P.E.
Re: Pleasant Grove Nursery 1 & 2
COC No. AWS310287
Duplin County
Dear Mr. Colson:
On behalf of Komegay Brothers, Inc., I am writing to inform you that construction on the
above referenced facility was started before August 27, 1997. If you have any questions,
please call me at [phone] ext. 4717.
Sincerely:
J. Neal Tucker, P.E.
Engineering Manager
cc: File
Kornegay Brothers, Inc.
Wilmington Regional Office - Water Quality Section
Post Office Box 759, Rose Hill, North Carolina 28458, [phone], FAX [phone]