310211_HISTORICAL_20171231

NUH I H UAHULINA
Department of Environmental Qual

'.1 PLAN OF ACTION (POA) FOR LAGOON SLUDGE REDUCTION
Facility Number. 31-211 Date: 8/6/2016 County: Duplin
Facility Name: Ricky Komegay Nursery Owner: Ricky T. Komegay
Certified Operator Name: Ricky T. Komegay Operator #: 18093
"Attach a copy of Lagoon Sludge Survey Form and volume worksheets
Note: A certified Sludge Management Plan may be submitted in lieu of this PDA.
La oon 1
Lagoon 2
Lagoon 3
Lagoon 4
Lagoon 5
a. Lagoon Namelldentifier
#1
b. Total Sludge Depth (ft)
3.92
c. Sludge Depth to be Removed
for Compliance (ft)
d. Sludge Volume to be
Removed(gals)
e. Sludge Slurry PAN
10
(lbs11000 gal
f. Liquid PAN
3.9
(Ibs11000 gal)
g. PAN of Sludge Slurry (Ibs)
d x e I1000
h. Sludge Materiel to be Bagged
350
cul ds
i. Bagged Sludge Approx. (gals)
259,000
h x 0.001351351
. Bagged Sludge Materiel in
227.5
tons h x .65
k. Bagged Sludge Material PAN
10
Ibsl1 ton
I. PAN of Bagged Sludge
'
Z275
Material Ibs x k
'e, f, & k. are sometimes averages and actual samples will be taken prior to land application or third party receiver such
as manure broker.
" i. is an approximation of slurry removal as compared to conventional slurry pump outs.
Compliance Timeframes:
If the sludge level is equal to or higher than the stop pump level of the lagoon or if the sludge level results in an elevated waste
analysis, a sludge management plan that meets the requirements of SB Interagency Group Guidance Document 1.26 must be
prepared by a technical specialist and submitted to DWR within 90 days. Work to reduce the sludge level must begin within another
180 days. Compliance with NRCS Standard 359 must be achieved within two years of the original sludge survey.
If the sludge level is noncompliant but below the stop pump level of the lagoon, a POA must be filed within 90 days and
compliance with NRCS Standard 359 must be achieved within two years of the original sludge survey indicating non-compliance. If
future sludge surveys do not show improvement in sludge levels, DWR may require the owner to develop a sludge management
plan that meets the requirements of SB Interagency Group Guidance Document 1.26. ECEIVE
SEP 13 2017
By
Ricky Komegay (31-211) - SPOA 7-28-2017 Page 1 Updated 9/13/2017

NARRATIVE: Use this section to describe the method(s) that will be used to lower sludge depth. If microbe use is
planned, specify the product to be used.
Conventional Methods
to contract a waste removal company to remove some or all of the required sludge by broadcasting onto fields not in my
utilization plan. I am aware, at that time I will need to have a sludge waste utilization plan.
memous
I plan to contract a bagging removal company to remove some or all of the required sludge by dewatering. I have included a site
map showing all locations that I may put a dewatering bag. The pad for the dewatering area will be lined with thick plastic so all
expelled waste water will be contained in a sump area and pumped back into lagoon or holding structure. The dewatering portion
of the project will vary according to amount removed, most projects will range from 1 to 4 weeks of actual pumping into the
dewatering bags weather -mechanical procedure permitting. The sump pumps shall remain intact and operational until the bag has
completely expelled all liquid waste. The sump pump shall remain operational until the dewatering bag is soilid and does not
actively drip, or weep into the sump area.) understand this area may NOT be on the lagoon embankment and at least 100 feet from
any well. If dewatering area is in my application field, the WUP will be updated to reflect the removal of this area until the
dewatering area is decommissioned and restored. Application fields will be avoided when all possible. Dewatered sludge should
have an active timeline to be removed from site not to exceed two years from date the bag is finished dewatering. It is required that
a sludge management plan be in place at the time of removal or before. If a manure broker accepts material it must be
documented by the producer and in accordance with the permit. See dewatering area details on the Temporary Start Pump
Adjustment for Sludge Removal with Dewatering Bag form.
Microbes Methods
I programs to be used will be the Agriment Services Inc. Program or other biological program or a more practical cost
program of that nature. The program will be reassessed for effetiveness and based on sludge surveys the frequency and
will be adjusted or discontinued to conventional removal method. It should be noted that a more aggressive approch to
Is treatment may involve agitation and inoculation of same bacterial blends.
Compliance Due Date: 12102017
Ricky Komegay
Facility Owner/Manager (print)
Facility er/M ager (i e)
Sludge Survey Date:
Return this form to:
Animal Feeding Operations Unit
NC Division of Water Resources
1636 Mail Service Center
Raleigh, NC 27699-1636
1211712015
Phone: [phone]
Date: 5/6/2016
Ricky Komegay (31-211) - SPOA 7-28-2017 2 of 3 Updated 9/13/2017

Facility Number: 311211 Date: 5/6/2016 County: Duplin
Facility Name: Ricky Komegay Nursery Owner: Ricky T. Kornegay
Location of Sump Area: SE Comer of Pad Bag Type: Agritube
Liner Specifications: 6 Mil Plastic
oon 1
Lagoon 2
Lagoon 3
Lagoon 4
Lagoon 5
a. Lagoon Name/Identifier
#1
b. Top of Dike (it)
54.0
c. Bottom of Dike (ft)
42.0
d. Length (ft)
170.0
e. Width (it)
140.0
f. Side Sloops
3.0
g. Stop Pump (ft)
50.1
h. Start Pump (ft)
52.4
L I" Lagoon Rise/Fall (gals)
(1 in./12 x d x e x 7.48gaVf6
. Length (it.)
14,835
De
68.0
watering
Area
7777771
k. Width (ft.)
44.0
I. Surface Area (sglft)
xk
2,992
m. Estimated Rainfall Cinches)
6.00
n. Estimated Rainfall (Gals)
M12in. x' x k x 7.48
11,190
o. Estimated Rainfall (tenths)
n! /12
0.06
p. Temporary Start Pump Level
(inches) b-h+o/12
20.0
'100% of the waste and stormwater from ciewatering area must be pumped back to the lagoon for as long as the waste
remains in the dewatering area. "This stored material should be moved within two years and a technical specialist will
generate a sludge management plan at that time of application or before. Producer will have a representative analysis 60
days before or after the application. 'if the waste is transferred to a third party manure broker, the producer must
provide a valid waste analysis at the time of transfer. All appropriated records for transfer of waste must be maintained in
accordance with the permit.
Date Started: 5(6(2016 Date Finished: 513112016
Ricky Komegay (31-211) - SPOA 7-28-2017 3 of 3 9/13/2017

PLAN OF ACTION (POA) FOR LAGOON SLUDGE REDUCTION
Facility Number. 31-211 Date: 8/6/2016 County: Dupiin
Facility Name: Ricky Komegay Nursery Owner: Ricky T. Komegay
Certified Operator Name: Ricky T. Komegay Operator #: 18093
"Attach a copy of Lagoon Sludge Survey Form and volume worksheets
Note: A certified Sludge Management Plan may be submitted in lieu of this PDA.
La oon 1
Lagoon 2
Lagoon 3
Lagoon 4
Lagoon 5
a. Lagoon Namelldenfifier
#1
b. Total Sludge Depth (ft)
3.92
c. Sludge Depth to be Removed
for Compliance (ft)
d. Sludge Volume to be
Removed(gals)
e. Sludge Slurry PAN
10
(Ibs11000 gal)
f. Liquid PAN
3.9
Ibs11000 gal)
g. PAN of Sludge Slurry (Ibs)
d x e /1000
h. Sludge Materiel to be Bagged
350
cul ds
i. Bagged Sludge Approx. (gals)
259,000
h x 0.001351351
. Bagged Sludge Materiel in
227.5
tons h x .65
k. Bagged Sludge Material PAN
10
Ibsl1 ton
I. PAN of Bagged Sludge
'
Z275
Material Ibs x k
le, f, & k. are sometimes averages and actual samples will be taken prior to land application or third party receiver such
as manure broker.
' 1. is an approximation of slurry removal as compared to conventional slurry pump outs.
Compliance Timeframes:
If the sludge level is equal to or higher than the stop pump level of the lagoon or if the sludge level results in an elevated waste
analysis, a sludge management plan that meets the requirements of SB Interagency Group Guidance Document 1.26 must be
prepared by a technical specialist and submitted to DWR within 90 days. Work to reduce the sludge level must begin within another
180 days. Compliance with NRCS Standard 359 must be achieved within two years of the original sludge survey.
If the sludge level is non -compliant but below the stop pump level of the lagoon, a PDA must be filed within 90 days and
compliance with NRCS Standard 359 must be achieved within two years of the original sludge survey indicating non-compliance. If
future sludge surveys do not show improvement in sludge levels, DWR may require the owner to develop a sludge management
plan that meets the requirements of SB Interagency Group Guidance Document 1.26.
Ricky Kornegay (31-211) - SPOA 7-28-2017 Page 1 Updated 9113/2017

NARRATIVE: Use this section to describe the method(s) that will be used to lower sludge depth. If microbe use is
planned, specify the product to be used.
Conventional Methods
plan to contract a waste removal company to remove some or all of the required sludge by broa
caste utilization plan. I am aware, at that time I will need to have a sludge waste utilization plan.
my
Bagging Methods
I plan to contract a bagging removal company to remove some or all of the required sludge by dewatering. I have included a site
map showing all locations that I may put a dewatering bag. The pad for the dewatering area will be lined with thick plastic so all
expelled waste water will be contained in a sump area and pumped back into lagoon or holding structure. The dewatering portion
of the project will vary according to amount removed, most projects will range from 1 to 4 weeks of actual pumping into the
dewatering bags weather -mechanical procedure permitting. The sump pumps shall remain intact and operational unfit the bag has
completely expelled all liquid waste. The sump pump shall remain operational until the dewatering bag is soilid and does not
actively drip, or weep into the sump areal understand this area may NOT be on the lagoon embankment and at least 100 feet from
any well. If dewatering area is in my application field, the WUP will be updated to reflect the removal of this area until the
dewatering area is decommissioned and restored. Application fields will be avoided when all possible. Dewatered sludge should
have an active timeline to be removed from site not to exceed two years from date the bag is finished dewatering. It is required that
a sludge management plan be in place at the time of removal or before. If a manure broker accepts material it must be
documented by the producer and in accordance with the permit. See dewatering area details on the Temporary Start Pump
Adjustment for Sludge Removal with Dewatering Bag form.
Microbes Methods
programs to be used will be the Agriment Services Inc. Program or other biological program or a more practical cost
xogram of that nature. The program will be reassessed for effetiveness and based on sludge surveys the frequency and
will be adjusted or discontinued to conventional removal method. It should be noted that a more aggressive approch to
s treatment may involve agitation and inoculation of same bacterial blends.
Compliance Due Date: 1211712017 Sludge Survey Date: 12(17/2015
Ricky Komegay
Facility Owner/Manager (print)
Facility OwherlMdnager (i e)
Return this form to:
Animal Feeding Operations Unit
NC Division of Water Resources
1636 Mail Service Center
Raleigh, NC 27699-1636
Phone: [phone]
Date: 5/6/2016
Ricky Komegay (31-211) - SPOA 7-28-2017 2 of 3 Updated 9/13/2017

Facility Number. 311211 Date: 51612016 County: Duplin
Facility Name: Ricky Komegay Nursery Owner. Ricky T. Kornegay
Location of Sump Area: SE Comer of Pad Bag Type: Agritube
Liner Specifications: 6 Mil Plastic
Lagoonl
Lagoon 2
Lagoon 3
Lagoon 4
Lagoon 5
a. Lagoon Name/ldentifier
#1
b. Top of Dike (ft)
54.0
c. Bottom of Dike (ft)
42.0
d. Length (ft)
170.0
e. Width (ft)
140.0
f. Side Sloops
3.0
g. Stop Pump (ft)
50.1
h. Start Pump (ft)
52.4
i.1' Lagoon Rise/Fall (gals)
(tin./12 x d x e x 7.48ga1fl6
'. Length (ft.)
14,835
Dewatering
68.0
Area
k. Width (ft.)
44.0
I. Surface Area (sq/ft)
'xk
Z992
m. Estimated Rainfall (inches)
6.00
n. Estimated Rainfall (Gals)
mll2in.x4xkx7.48
11,190
o. Estimated Rainfall (tenths)
n1i /12
0.06
p. Temporary Start Pump Level
inches b-h+o/12
20.0
'100% of the waste and stormwater from dewatering area must be pumped back to the lagoon for as long as the waste
remains in the dewatering area. "This stored material should be moved within two years and a technical specialist will
generate a sludge management plan at that time of application or before. Producer will have a representative analysis 60
days before or after the application. 'if the waste is transferred to a third party manure broker, the producer must
provide a valid waste analysis at the time of transfer. All appropriated records for transfer of waste must be maintained in
accordance with the permit.
Date Started: 5/6/2016
Date Finished: 513112016
Ricky Komegay (31-211) - SPOA 7-28-2017 3 of 3 9/13/2017

WASTE UTILIZATION PLAN
Goldsboro Hog Farms, Inc.
li l Tuesday, May 14, 1996
Producer: Ricky T. Kornegay
Farm Name:
Telephone # :
Type of Operation
Number of Animals:
Application Method:
Ricky Komegay
756 NC 403 West
Mt Olive,NC 28365
(919) 65MM1
Wean to Feeder Swine
32(10 pigs design capacity
Irrigation
APR 0 8 2009
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface and/or groundwater. The plant nutrients in.the animal waste should be
used to reduce the amount of commercial fertilizer required for the crops in the fields where
waste is to be applied. This waste utilization plan.uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil tests are strongly
encouraged so that all plant nutrients can be balanced for realistic yields of the crop to be
grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
contents of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
IM important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and avaialable water holding capacities. Normally waste shall not be applied to
land eroding at greater than 5 tons per acre per year. With special pre -cautions, waste may
be applied to land eroding at up to 10 tons per acre per year. Do not apply waste on
saturated soils, when it is raining, or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed under DEM'regulations. Wind
conditions should also be considered to avoid drift and downwind odor problems. To
maximize the value of the nutrients for crop production and to reduce the potential for
pollution, the waste should be applied to a growing crop or applied to bare ground not more
than 30 days prior to planting.. Injecting the waste or disking will conserve nutrients and
reduce odor problems. This plan is baled on waste application through irrigation for this is
the manner in which you have chosen to apply your waste. If you choose to inject the waste
in the future, you need to revise this plan. Nutrient levels for injecting waste and irrigating
waste are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for ananlysis. This waste
utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H.0217 adopted by the Environmental Management Commission.
RECEIVED I DENR I uwu
AQUIFFR-PPnTFcnrW QFCTION
MAR 31 7nnq
Page 1

AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
3200 pigs X 0.4 tons waste/pigs/year = 1280 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
3200 pigs X 0.48 Ibs PAN/pigs/year = 1636 PAN/year
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on the crop to be grown,
soil type and suface application.
TABLE 1 : ACRES OWNED BY PRODUCER
TRACT FIELD SOIL TYPE &CLASS- CROP YIELD LOS AW COMM ACRES LOS AW APPLIC.
DETERMINe1G.PNASE CODE NIACRE WACRE USED TIME
71204
2
AUTRYVILLE ALL
BH
5.5
275:
0
3.18
874.5
MAR-OCT-
71204
- 2
AUTRYVILLE ALL
SG
1
50
0
3.181
1591
SEP-MAR
71204
3
ALITRYVILLE ALL
BH
5.5
275
0
2.4621
677.05
MAR-OCT
71204
- 3
ALFrRYVILLE ALL
SG
1
50
0
2.462
123.1
SEP-MAR
TOTALS: 1833.66.
Indicates that this field is being overseeded (i.e. interpianted) or winter annuals follow
summer annuals.
' Indicates a Crop Rotation
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N
requirments. Beginning:in 1996 the Coastal Zone. Management Act will require farmers in
some eastern counties of NC to have a nutrient management plan that addresses all
`-' nutrients. This plan only addresses Nitrogen.
149
Page 2

TABLE 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
1-1
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land. See required specifications 2.)
There are no Acres Leased
— Indicates that this field is being overseeded (i.e. interplanted) or winter annuals follow
summer annuals.
Indicates a Crop Rotation
" Acreage figures may exceed total acreage in field due to overseeding.
"Lbs AW N (animal waste nitrogen) equals total required nitrogen less any commercial
nitrogen (COMM N) supplied.
The following legend explains the crop codes used in TABLES 1 and 2 above:
CROP CODE CROP UNITS LBS WUNIT
aH
HYBRID eERMUDAGRASS-HAY
TONS
50
SG
_
SMALL GRAIN OVERSEEDED
Ac
50
Page 3

TOTALS FROM TABLES 1 AND 2
ACRES Las Aw
N USED
ABLE 1 5.642 1.834
�. TOTALS: 5.6421 1,834
ANOUNT OF N PRODUCED: 1,536
BALANCE -298
This number must be less than or equal to 0 in order to fully utilize the animal waste N
produced.
Acres show in each of the preceeding tables are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter
areas not receiving full application rates due to equipment limitations. Actual total acres in the
fields listed may, and most likely will be, more than the acres shown in'the tables.
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of
sludge at agronomic rates. The sludge will be nurturient rich and will require precautionary
measures to prevent over application of nutrients or other elements. Your production facility
will produce approximately 243.2 pounds of plant available nitrogen (PAN) per year in the
sludge that will need to be removed on a periodic basis. This figure is •PAN when
broadcasting the sludge. Please be aware that additional acres of land, as well special
equipment, may be needed when you remove this sludge.
See the attached map showing the fields to be used for the utilization of waste water.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the soil'at the time of
irrigation such that runoff or ponding occurs. This rate. is limited by initial soil; moisture
content, soil structure, soil texture, water droplet size, and organic solids. The application
v amount should not exceed the available water holding capacity of the soil at the time of
irrigation nor should the plant available nitrogen applied exceed the nitrogen needs of the
crop.
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every 5.92 months. In no instance:should the volume of
waste being stored in your structure be within 1.8 feet of the top of the dike.
If surface irrigation is the method of land application for this plan, it is the responsiblity of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in Tables 1 and 2. Failure to apply the recommended rates and
amounts of Nitrogen shown in.the tables may make this plan invalid.
The following table is provided as a guide for establishing application rates and amounts.
APPLICATION APPLICATION
TRACT FIELD SOIL TYPE CROP RATE (Inlhh ANIT (linos)
71204 -2,-3
UTRYVILLEALL
SG
0.60
`t
71204 1_ 2,3
JAVTRYVILLE ALL
BH
0.60
'1
This is the maximum application amount allowed for the soil assuming the amount of
nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Page 4

NARRATIVE OF OPERATION
This WUP has been revised to reflect wettable acres as determined by Starr Maready,
Certified Technical Specialist, WANVUP, Duplin Co. Cooperative Extension office. A map
and the computations were furnished by Starr Maready.
This WUP was amended 12/14/00 to change the forage crops from grazed to hay.
Wof FgDW4M fN MMION (,r{rttJls�p vuE 7a G4ik+IGE of OW,yekSahp b-D�-Oy.
Page 5

PLANS & SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application. Any
j discharge of waste which reaches surface water is prohibited. Illegal discharges are subject
. i to assessment of civil penalties of $10,000 per day by the Division of Water Quality for every
day the discharge continues.
2. The Field Office must have documentation in the design folder that the producer either
owns or has long term access to adequate land to properly dispose of waste. If the producer
does not own adequate land to property dispose of waste, he shall provide NRCS with a copy
of a written agreement with a landowner who is within a reasonable proximity, allowing
him/her the use of.the land for waste application for the life expectancy of the production
facility. It is the responsibility of the owner of the facility to secure an update of the Waste
Utilization Plan when there is a change in the operation, increase in the number of animals,
method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climate conditions, and level of
management, unless there are regulations that restrict the rate of application for other
nutrients.
4. Animal waste may be applied to land that has a Resource Management System (RMS) or
an Alternative Conservation System (ACS). If an ACS is used the soil loss shall be no greater
than 10 tons per acre per year and appropriate filter strips will be used where runoff leaves
the field. These filter strips will be in addition to "Buffers" required by DEM: (See FOTG
Stantard 393 - Fitter Strips and Standard 390 Interim Riparian Forest Buffers).
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field;
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to; conservation tilled crops or grassland, the
waste may be broadcast,provided'the application does not occur during a. season,prone to
flooding. (See "Weather. and Climate in North Carolina" in the NRCS Technical Reference -
Environment file for guidance.)
'7. liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order to control conditions conducive
to odor or flies and to provide uniformity of application.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with
a high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste shall
not be applied more than 30 days prior to planting; of a crop on bare soil.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following:
the outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
Page 6

and from any perennial stream or river (other that an irrigation ditch or canal. Animal waste
other than swine waste from facilities sited on or after October 1, 1995), shall not be applied
closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal Waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landownwer.
14. Waste shall be applied in a manner not to reach other property and public right - of ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted croplands
provided they have been approved as a land application site by a 'technical specialist'.
Animal waste should. not be applied on grassed waterways that discharge directly into water
courses, except when applied at agronomic rates and the application causes no runoff or drift
from the site.
•16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc.,
shall not be discharged into the animal waste management system.
'17. A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). If needed, special vegetation shall be
provided for these areas and shall be fenced, as necessary, to protect the vegetation.
Vegetation such as trees, shrubs, and other woody species, etc. are limited to areas where
considered appropriate. Lagoon areas should be kept mowed and accessible. Lagoon berms
and structures should be inspected regularly for evidence of erosion, leakage or discharge.
•18. If animal production at the facility is to be suspended or terminated, the owner is
' responsible for obtaining and implementing a "closure plan" which will eliminate the possibility
of an illegal discharge, pollution and erosion.
*19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks, and spills. A regular maintenance checklist should be
kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied as a preemergenoe with no other applications of
animal waste during the crop season.
*21. Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste .treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to mark
the maximum storage volume fpr waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soils shall be monitored and alternative crop sites
shall be used when these metals approach excessive levels. pH shall be adjusted for
optimum crop production amd maintained. Soil and waste analysis records -shall be kept for
five (5) years. Poultry dry waste application records shall be maintained for three (3) years.
Waste application records for all other waste shall be maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina Department of
Agriculture regulations.
Page 7

NAME OF FARM: Ricky Kornegay
OWNER / MANAGER AGREEMENT
I (we) understand and will follow and implement the specifications and the operation and
maintenance precedures estalished in the approved animal waste utilization plan for the farm
named above. I (we) know that any expansion to the existing design capacity of the waste
treatment and/or storage system or construction of new facilities will require a new utilization
plan and a new certification to be submitted to DEKI before the new animals are stocked.
I (we) understand that I must own or have acces to equipment, primarily irrigation equipment,
to land apply the animal waste described in this waste utilization plan. This equipment must
be available at the appropriate pumping time such that no discharge occurs from the lagoon
in a 25-year 1-day storm event. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates that no runoff occurs.
NAME OF FACILITY OWNER: Ricky T. Kornegay
SIGNATURET�. DATE —v
NAME OF MANAGER (if different from owner):
please print
SIGNATURE: _ DATE:
NAME OF TECHNICAL SPECIALIST: George H. Pettus
AFFILIATION: Goldsboro Hog Farms, Inc.
ADDRESS (AGENCY): PO Box 10009
Goldsboro, NC 27532
[phone]
SIGNATURE: _ DATE:
Page 9

31-2//
Michael F. Easley, Governor
E
i!' �'IVED William G. Ross Jr., Secretary
JUN 3��04 No Carolina Department of Environment and Natural Resources
Alan W. Klimek, P. E., Director
Division of Water Quality
June 25, 2004
Ricky T. Korgegay
Ricky Komegay Farm
756 NC 403 West
Mt. Olive NC 28365
Subject: Certificate of Coverage No. AWS310211
Ricky Komegay Farm
Swine Waste Collection, Treatment,
Storage and Application System
Duplin County
Dear Ricky T. Korgegay:
In accordance with your Notification of Change of Ownership received on June 15, 2004 and in
accordance with the directive of Senate Bill 733, we are hereby forwarding to you this Certificate of
Coverage (COC) issued to Ricky T. Korgegay, authorizing the operation of the subject animal waste
collection, treatment, storage and land application system in accordance with General Permit
AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Ricky Komegay Farm, located in Duplin County, with an animal capacity of no
greater than an annual average of 3200 Wean to Feeder swine and the application to land as specified in
the facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or
Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary,
they may be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a
rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until October 1, 2004, and shall hereby void
Certificate of Coverage Number AWS310211 dated May 1, 2003, and shall be subject to the conditions
and limitations as specified therein. Pursuant to this COC, you are authorized and required to operate the
system in conformity with the conditions and limitations as specified in the General Pemrit, the facility's
CAWMP, and this COC. An adequate system for collecting and maintaining the required monitoring data
and operational information must be established for this facility. Any increase in waste production
greater than the certified design capacity or increase in number of animals authorized by this COC (as
provided above) will require a modification to the CAWMP and this COC and must be completed prior to
actual increase in either wastewater flow or number of animals.
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Non -Discharge Permitting Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
Internet http://h2o.enr.state.m.us/ndpu-
Telephone [phone] Fax [phone]
Telephone [phone]
50% recycled/109/ post -consumer paper
Customer Service Center
An Equal Opportunity Action Employer

Per NRCS standards a 100 foot separation shall be maintained between water supply wells and any
lagoon or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application fur reuewai urusi ue lucd at leant 1081V days prior to expo..don.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Wilmington Regional Office. The Regional Office. .
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact J R Joshi at [phone] ext. 363.
Sincerely,
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
C—Wilmington Regional-Office,—Water-Quality_Section7
Duplin County Health Department
Duplin County Soil and Water Conservation District
Permit File AWS310211
NDPU Files

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
Michael F. Easley, Governor
William G. Ross Jr., Secretary
Kerr T. Stevens, Director
STANLEY CURTIS BROCK
PIGS "R" US, INC.
4220 N HWY 111
ALBERTSON NC 28508
Dear Mr. Brock:
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
May 11, 2001 I MAY 16 2001
Subject: Certificate of Coverage No. AWS310211
Pigs "R" Us, Inc.
Swine Waste Collection, Treatment,
Storage and Application System
Duplin County
In accordance with your application received on December 5, 2000, we are forwarding this
Certificate of Coverage (COC) issued to Stanley Curtis Brock, authorizing the operation of the subject
animal waste collection, treatment, storage and land application system in accordance with General
Permit AWG100000. This approval shall consist of the operation of this system including, but not
limited to, the management of animal waste from the Pigs "R" Us, Inc. facility, located in Duplin
County, with an animal capacity of no greater than 3200 Wean to Feeder swine and the application to
land as specified in the Certified Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations
as specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and. shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General
Permit or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS
143-215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Certificate of Coverage AWS310211
Pigs "R" Us, Inc.
Page 2
Upon notification by the Division of this COC's expiration, you shafl apply for its renewal. This
request shall be made within 30 days of notification by the Division.
This COC is not automatically transferable. A name/ownership change application must be
submitted to the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the
right to apply for an individual non -discharge permit by contacting the engineer listed below for
information on this process. Unless such a request is made within 30 days, this COC shall be final and
binding.
The subject farm is located in the Wilmington Regional Office. The Regional Office Water
Quality Staff may be reached at [phone]. If you need additional information concerning this
COC or the General Permit, please contact Theresa Nartea at [phone] ext. 375.
Sincerely,
:::� - LD
err T. Stevens
cc: (Certificate of Coverage only for all cc's)
Duplin County Health Department
Wilmington Regional Office, Water Quality Section
Duplin County Soil and Water Conservation District
George Pettus -Goldsboro Hog Farms
Permit File
NDPU Files

State of North Carolina
Department of Environment and Natural Resources
Division of Water Quality
Non -Discharge Permit Application Form
(THIS FORM MAYBE PHOTOCOPIED FOR USE AS AN ORIGINAL)
General Permit - Existing Animal Waste Operations
The following questions have been completed utilizing information on file with the Division. Please
review the information for completeness and make any corrections that are appropriate. If a
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
GENERAL INFORMATION:
1.1 Facility Name:
RECEIVED
DEC 5 2VJ
1.2 Print Land Owner's name: Stanley Curtis Brock WA:FF=P QUALITY SECTION
1.3 Mailing address: 4220 N Hwy 1 I I Non -Discharge Permitting
Citv. State: Albertson NC Zip:
Telephone Number (include area code):
1.4 County where facility is located:
1.5 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a copy
of a county road map with the location of the farm identified): Northwest of Albertson. On North side of Hwy I I I just
1.6 Print Farm Manager's name (if different from Land Owner):
1.7 Lessee's / Integrator's name (if applicable; please circle which type is listed): Goldsboro Hoe Farms
1.8 Date Facility Originally Began Operation: 1/1/
1.9 Date(s) of Facility Expansion(s) (if applicable):
2. OPERATION INFORMATION:
2.1 Facility No.: 31_ (county number); 211 (facility number).
2.2 Operation Description: Swine operation
Wean to Feeder
3200- Certified Design Capacity
Is the above information correct? Dyes; [::]no. If no, correct below using the design capacity of the facility
The "No. of Animals" should be the maximum number for which the waste management structures were designed.
Type of Swine No. of Animals Type of Poultry No. of Animals Type of Cattle No. of Animals
0 Wean to Feeder 0 Layer 0 Dairy
0 Feeder to Finish 0 Non -Layer 0 Beef
0 Farrow to Wean (# sow) 0 Turkey
0 Farrow to Feeder (# sow)
0 Farrow to Finish (# sow)
Other Type of Livestock on the farm: XJ No. of Animals:
FORM: AWO-G-E 7/7/99 Page 1 of 4 31- 211

RECEIVE®
Facility Number: 31 - 211
Facility Name: Pigs R Us Inc DEC , 20L. I
4. APPLICANT'S CERTIFICATION: WATER QUALITY SECTION
1, s�&vtIey c t r- j (3f-tx.k Non-DischxCaP tt ^
(�.dfit tl`Olner's name listed in question 1.2), attest that
this application for f IDS S 1e. US (Facility name listed in question 1.1)
has been reviewed by m ae ndis accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be returned to me as incomplete.
Signature
Date I I- / ✓ - a 0
5. MANAGER'S CERTIFICATION: (complete only if different from the Land Owner)
(Manager's name listed in question 1.6), attest that this
application for (Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be returned as incomplete.
Signature
Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
1617 MAIL SERVICE CENTER
RALEIGH, NORTH CAROLINA 27699-1617
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
FORM: AWO-G-E 7/7/99 Page 3 of 4 31- 211

b
a �U•
��yy U rl
���Frn � � � Gt •� cl�r1 it
Ul
vl FJ•u,�j � o
Ch
it it
N'
00
a
dit
ba
I. CO li,
In ,O 1�
_ p .q
O �I r T O' ��J i" �i
'r {� T! I !1 2
it it rl 0 R W ,n ci i •n •R " 111 i•� •� :J tJ i k W!
O o °� 7v[l iQ c rl . (v Ir vlW 1 U (k IK In Init Ili U1
m`y lu ' P vY1
zr'7�i'aXJ.? 11 f�
p 4r1 m ,r °'1 ��ZI`
ia
j, �+
Q ,•L � l.. il, •� !A fl1 � U � i1, iQ ti 14 1}:It. Llt, mil. (n il, i I °' 1� ii �i 1- Y
q'� I� h � 1. 11, •a

WASTE UTILIZATION PLAN
Goldsboro Hog Farms, Inc.
Tuesday, May 14, 1996
Producer: Curtis Brock
Farm Name:
Telephone # :
Type of Operation
Number of Animals:
Application Method:
Pigs'R" Us
4220 N Hwy 111
Albertson,NC 28508
[phone]
Wean to Feeder swine
3200 pigs design capacity
Irrigation
R5CEIVED
DEC 5 20t!)
WATER QUALITY SECTION
Non -Discharge permitting
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface and/or groundwater. The plant nutrients in the animal waste should be
used to reduce the amount of commercial fertilizer required for the crops in the fields where
waste is to be applied. This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil tests are strongly
encouraged so that all plant nutrients can be balanced for realistic yields of the crop to be
grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
contents of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and avaialable water holding capacities. Normally waste shall not be applied to
land eroding at greater than 5 tons per acre per year. With special pre -cautions, waste may
be applied to land eroding at up to 10 tons per acre per year. Do not apply waste on
saturated soils, when it is raining, or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed under DEM regulations. Wind
conditions should also be considered to avoid drift and downwind odor problems. To
maximize the value of the nutrients for crop production and to reduce the potential for
pollution, the waste should be applied to a growing crop or applied to bare ground not more
than 30 days prior to planting. Injecting the waste or disking will conserve nutrients and
reduce odor problems. This plan is based on waste application through irrigation for this is
the manner in which you have chosen to apply your waste. If you choose to inject the waste
in the future, you need to revise this plan. Nutrient levels for injecting waste and irrigating
waste are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for ananlysis. This waste
utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H.0217 adopted by the Environmental Management Commission.
Page 1 of 9

I J.S. nEPAQT4Ar NT OP tkI,IWCUI.1 UP
SnL_CONSERVATION SERVICE SCS •CPA -16
� CONSERVATION PLAN MAP2 -fll
--i==—� Operator
Count}' 7 0 Stnt, Date �-11- 9 -L
Approximate acres. Approximate scale /"_ 6t.,U'
Cooperating with_�,.nl> Conservation District
i Plan identification I - it 20 y Photo numbers ASCS - 1991 K--z
f Assisted by t�icW5on USDA Soil Conservation Service
r-5
I` ' �� ��% nyif�''� •41..��'L�� ti• \,�V�M1 ' L,'.
di �,`"N�� 15" T4s.� 17 t., �a'e �% .l°1 1 i � y1 i'i4�•�it,�ij,�X4�nFt 1?k. i.1,'d` 7-
a-
c �3
�. J M Llq�rucR"iow''
A�o�j �y4
�a P � I� 5�r'
W ;.
r
,
1
Up
"I
y
4..
wr

'Irrigation System Calibration Data Sheet for Stationary Sprinkler
Date - 99 Farm / i ract No. %/a 041
a. Effective sprinkler area: Lateral spacing It by spacing along lateral ft =
r
Sprinkler: Make d5gr_) Model 1h0 Nozzle Dia. ��crg he�� GPM
se
Pressure: Sprinkler LJ A Pump Pressure '7D
b. Spacing between collection containers (sprinklers spacing 9 (ft) � = L It
/lO 9 '
c. Number of collection containers _
,5^ 9,3. 47 :, 15 19
d. Start of Irrigation event 7 n 5A —0 1_J 0 U 0 t3 — V
J^.^ ., / 6� , oo , 4 , s 1 O 16O 30-11
f
e. End of Irrigation event [V�f
O r0 'O 'O 'O 2G ZG 'n
f. Duration (e-d) (2-Dn hours
g. Operate the system, collect data, and
record on the worksheet on page 18.
h. Sum of all catches —.7 inches
O a0 0 ZO ZO ZO
i. Average application depth (h/c) •39-5 inches
Wd
j. Precipitation rate = W 395
inches/hr= .193
(� 9-C6 .y
k. Sum of all deviations from the average catch J LL
I. Average deviation from average application depth ,
164
m. Uniformity coefficient
UC= x too= 5&5%
Interpret the calibration results.
An application uniformity greater than
75 is excellent for stationary sprinklers.
Application uniformity between 50 to
75 is in the "good" range and is
acceptable for wastewater application.
venerauy, an application uniformity
below 50 is not acceptable for waste-
water irrigation. If the computed U. is
less than 50 percent, system adjustments
are required. Contact your irrigation
dealer or Certified Technical Specialist
for assistance.
It,
ddl
O
Wind direction
2
U4
op
19'

Field Calibration Procedures
for Animal Wastewater Application Equipment
Calibration Data Sheet for Stationary Sprinkler (continued)
Gauge No. Volume Overlap Corrected Deviation
Collected Adjustment Volume from Average*
1
3 -
-
2
38
—
— ox5
4
�
() 0 5
5
l0O
, O 5
6
7
9
/
10
11
12
13
/
14
15
/
16
17
18
7 5
19
.310 —
.035
20
_
—
—5
21
22
t✓
a%5
23
24
25
26
27
28
29
30
31
32
'Treat all values as positive

UNITED STATES
DEPARTMENT OF
AGRICULTURE
-------------
SOIL
CONSERVATION
SERVICE
WASTE MANAGEMENT FACILITY SITE EVALUATION
GENERAL INFORMATION
NAMEIA s"-
------------------------
------------------------
TELEPHONE-1L1:!- `E4E=39j� -----
LOCATION-Qn--b-L J1L max_
iQ�b--
------------------
SIZE OPERATION-?-,--2�1�60' I
LOCATION DATA
DISTANCE FROM NEAREST RESIDENCE NOT OWNED BY
PRODUCER -2p0--FT. U"lu!
IS SITE WITHIN 100-YEAR FLOOD PLAIN? YES----- NO f
If yes, SCS cannot provide assistance.
IS SITE AT LEAST 100 FT. FROM A "BLUE LINE"
PERENNIAL STREAM? YES----- NO ----
If no, site must be relocated.
IS SITE WITHIN 1 MILE ZONING JURISDICTION
OF A MUNICIPALITY? YES----- NO -
If yes, landowner should consult with local zoning board
about required permits. Permits must be obtained prior
to design approval.
Are utilities in construction area? YES----- NO-' -
If yes, see Part 503 of the National Engineering Manual
and follow policy.
(Copies of maps or other reference materials may be
attached to site evaluation.)
Page 1

WETLANDS
WILL SITE INVOLVE CLEARING WOODLAND OR ANY
NON -CROPLAND? YES----- NO
If yes, producer must complete a Form AD-1026.
WILL ACTION RESULT IN SWAMPBUSTING? YES---- NO ----
IF WETLANDS ARE INVOLVED, IT IS THE RESPONSIBILITY OF THE
PRODUCER TO CONTACT THE US ARMY CORP OF ENGINEERS AND THE
DIVISION OF ENVIRONMENTAL MANAGEMENT TO DETERMINE IF
ADDITIONAL PERMITS ARE REQUIRED. NO WETLANDS SHOULD BE
ALTERED UNTIL PRODUCER RECEIVES WRITTEN APPROVAL FROM SCS,
US ARMY CORP OF ENGINEERS AND NC DIVISION OF ENVIRONMENTAL
MANAGEMENT.
(A copy of AD-1026 and CPA-026 should be attached to
site evaluation.)
OTHER ENVIRONMENTAL FACTORS
IS ENDANGERED AND/OR THREATENED SPECIES HABITAT
PRESENT? YES---- NO`---
IS A DESIGNATED NATURAL SCENIC AREA INCLUDED IN THE
PLANNING AREA OR WILL PLANNED ACTIONS IMPACT ON AN
ADJACENT NATURAL SCENIC AREA? YES---- NO ----
IS AN ARCHAEOLOGICAL OR HISTORICAL SITE LOCATED IN THE
PLANNED AREA? YES---- NO
ARE THERE PRIME, UNIQUE, STATE OR LOCALLY IMPORTANT
FARMLANDS IN THE OPERATING UNIT? 4,JS YES-'-- NO ----
WILL THE ACTION RESULT IN SODBUSTING? YES----
If yes to any of' these questi�ons, refer to form NC-CPA-16
for policy sources. The formldoes not need to be
completed.
ODOR CONTROL
HAS ODOR CONTROL BEEN DISCUSSED WITH PRODUCER.........
........PREDOMINANT WIND DIRECTION? YES---- NO ----
........POSSIBLE EXPANSION OF TREATMENT
VOLUME FROM 1 CU.FT. UPWARDS TO
3 CU. FT./LB. OF ANIMAL? YES---- NO----
........PRECHARGING LAGOON WITH FRESH
WATER TO AT LEAST 1/2 OF THE
CAPACITY? YES---- NO ----
........USING GOOD SOUND JUDGMENT IN
LAND APPLICATION OF WASTE? YES---- NO ----
Page 2

WASTE MANAGEMENT
DOES PRODUCER OWN ENOUGH LAND TO PROPERLY
YESND/-;,,, --
APPLY WASTE?
IF NO, DOES PRODUCER HAVE ACCESS TO
MORE LAND? YES---- NO ----
IF LAND IS NOT OWNED BY PRODUCER,
CAN PRODUCER GET AGREEMENT ON LAND
ON WHICH TO APPLY WASTE? YES---- NO ----
(Attach Waste Utilization Plan to site evaluation.)
SOIL INVESTIGATION -- VALID ONLY IF
SHEET ATTACHED
IS SOIL SUITABLE FOR LAGOON?
IS A CLAY LINER REQUIRED?
IF YES, IS CLAY AVAILABLE ONSITE?
SOIL INVESTIGATION
IS A CORE TRENCH REQUIRED?
(Attach soil investigation sheet to
YES-- ✓ - NO ------
YES------ NO 1 ---
YES------ NO------
QUESTIONABLE--------
YES--1:f:f-- NO------
siteevaluation.)
SITE APPROVED YES-`=-- NO----- CONDITIONAL --------
COMMENTS---
(�G=---------------------------------------------------
THIS SITE INVESTIGATION IS VALID AS LONG AS THE DESIGN AND
CONSTRUCTION OF LAGOON CONTINUES IN REASONABLE TIME
PERIOD. UNDUE DELAYS OR HESITANCY IN CONSTRUCTION MAY
REQUIRE THAT SITE EVALUATION BE INVALIDATED.
SIGNAT URE-1'&—--��� -- DATE `�-L-4y---
RBv�5tc1
Page 3

uj
BD
cc
w
io
c
m-IIL
c
CID
F
CN,
Lj
L
z
U a
0 It,
c
zj CID,
0
Q L
C
CL
G TE
Ll L
--u
In IJ
til
M C L
Lirl
Ul
U) Ij u
AJ '4- U
L IT)
at 1:
Z Ul 4j
.13
a'
cl 41
to
17 'n
IL
4 C Jul
C) 0
tn�G
0
>
Ll iJ
'T,
&
u' Ill
at
T, it
Ij
3
aj
at
at aj
aj Jz
at Ll
c V
C. 4j
c
ai
a, cr.;
-W la
"L On
L
0
all
,a c aj
'T" at
c
L
at
L
iti Ll
Ip 0
L
all
>
C. p
L
fit L
> ai
cl C,
!It
0
L -
01 r-
at
L 4J
-C.
4� 0
Ul
.. C
T_
at
U;
at
L , L
it,
-if
c
M.
U
u
al
c
11 CIO
0 C.
L P.
4 LID
Qj 04
ul z
-M -r-. J
L
7j X
L) c
at
L
I
t

DEPARTMENT OF THE ARMY
WILMINGTON DISTRICT, CORPS OF ENGINEERS
P.O. BOX 1890
WILMINGTON. NORTH CAROLINA 28402-1890
November 20, 1991
IN REPLY REFER TO
Regulatory Branch
Action ID. 199200281, Nationwide Permit No. 26 RC r ENED
Mr. Stanley Curtis Brock [� II
Route 1, Box 164 C �y,C(�
L`�}
Albertson, North Carolina 28508
WATER QN%�-I� SECTION
Dear Mr. Brock: NonDls�ha*5�P'��ihn9
Reference your application of October 10, 1991, for Department of the
Army authorization to impact 0.3 acre of wetlands to upgrade a road and
install a permanent utility line, resulting in impacts to approximately
0.2 acre of wetlands in association with a hog farm, on a tributary to the
Northeast Cape Fear River, off N.C. Ill near its intersection with S.R. 1537
near Albertson in Duplin County, North Carolina.
For the purposes of the Corps of Engineers' Regulatory Program, Title
33, Code of Federal Regulations (CFR), Part 330, published in the Federal
Register on November 13, 1986, lists nationwide permits. Authorization was
provided for discharges of dredged or fill material into non -tidal rivers,
streams, and their lakes and impoundments, including adjacent wetlands, that
are located above the headwaters and other non -tidal waters of the United
States, including adjacent wetlands, that are not a part of a surface
tributary system to interstate waters or navigable waters of the United
States.
Your work is authorized by nationwide permit provided it is accomplished
in strict accordance with the enclosed conditions. The nationwide permit
does not relieve you of the responsibility to obtain any required State or
local approval.
This verification will be valid until the nationwide permit is modified,
reissued or revoked. All nationwide permits are scheduled to be modified,
reissued or revoked prior to January 13, 1992. It is incumbent upon you to
remain informed of changes to the nationwide permits. We will issue a
public notice announcing changes when they occur. Furthermore, if you
commence or are under contract to commence this activity before the date the
nationwide permit is modified or revoked, you will have 12 months from the
date of the modification or revocation to complete the activity under the
present terms and conditions of this nationwide permit.
Questions or comments may be addressed to Mr. Jeff Richter, Regulatory
Branch, telephone [phone].
Sincerely,
G. Wayne Wright
Chief, Regulatory Branch
Enclosure

-2-
Copies Furnished (without enclosure):
Mr. John Parker
North Carolina Department of
Environment, Health and
Natural Resources
Post Office Box 27687
Raleigh, North Carolina 27611-7687
Mr. John Dorney
Water quality Section
Division of Environmental Management
North Carolina Department of
Environment, Health and
Natural Resources
Post Office Box 27687
Raleigh, North Carolina 27611-7687
Mr. Jim Gregson
North Carolina Department of
Environment, Health and
Natural Resources
Division of Environmental Management
127 Cardinal Drive Extension
Wilmington, North Carolina 28405-3845
Mr. Billy Houston
Duplin County Soil
onservation Service
Post Office Box 277
Kenansville, North Carolina 28349
E:'

I

:c Umted States
Decartment Ot
Agriculture
So.[
conservation
Service
OPERATOR: 15� hlej Cvr±ic Bro
Please review the attached °plan and specifications carefully. Retain
this plan for your use and records. It is strongly recommended that you,
your contractor, and Soil Conservation Service personnel are in agreement
as to how the waste lagoon is to be constructed. The Soil Conservation
Service personnel will meet with all concerned parties and walk over the
site to explain all flags and markings. It is important that everyone
understand what is expected so that final construction meets plans and
specification and the job can be certified for payment (if cost -sharing
is involved).
The pad dimensions and grades are the best estimate. The BUILDER or �
CONTRACTOR is RESPONSIBLE for final layout and design of the pads. The
Soil Conservation Service personnel will assist in a limited capacity,
as its major concern is the proper design and'construction of the waste
treatment lagoon.
The actual amount of material required for pads and'dam may vary from the
estimates. The design wil'I attempt to balance cuts and fills as close as
possible. If additional material is required after construction is complete
on the lagoon, the contractor and owner will negotiate on the price and
location of borrow area. .A
NOTE: Design Requirement: 149.S34cu.ft. = SS3k cu.yds.
Estimate of Excavation: cu.ft. = J1 p-Lcu.yds.
Estimate of Pad L Dike: cu.ft. = 317-8 u.yds.
,4:L Ration
_Job Class �_ 3_17_.g2-
Date
Designed By (jjp.-� %n2� 2t�r
N�ame
Design Approval % F 'l
Name
Date
C'*/Fill etccesrivt dvc iro rede,riyn of- Pool
as rcgvas}cd by Tr^ Price GoI46np f}o9 Fprrf.
O Tna Soa Censarvabn SoM q
a
Van agency of tna
Oaaanmant of Agmwtwa

Sonic-f. CvrYiy QroGk
H1be, t,-- , NC
,�- IS1U /Vvrl <ry
�-
P7 64
BEFORE BEGINNING EXCAVATION
LANDOWNER IS ADVISED TO CONTACT
ULOCO TO ASSURE THAT UNDERGROUND
UTILITIES ARE NOT DESTROYED 1-800-
632-4949

gPEMATICH QND W!INTF!',!i_110E 1:11-pN
_�his \�ucos is i icsiUno'1 p mest wi�h
control. The time required for thc planned fluid leve' _�z be
naary d"e to ' Sil cncjitions,flU ing c|��ra�
'he amuynt of f,esh water add�c! to the system.
Land application of waste water i!- rec»yvicnd as an acca:-,lo
muthod of disposal. Methods of application include sc1zd set,
center- pivot, guns, and traveling gun irrigation. Care h,
taken wh-en applying waste to prevent runoff from the field or dauiag�
to cr-Ps.
The following items are to be carried nut-
1. It is strongly recommended thet the treatment lagoen be prp-
charged to 1/-- its capacity to prevent excessive odors du.`ing
start --up. Pre -charging reduces th.e concentration of- thu, initial
�aste entering the lagoon thereby reUucing odors. Sulids shuyl6 b e
covered with effluent at all times.
�I r- attEtch ed waste ytilizaticn plan shallhe followi!d. Th1s
plan recommends sanpling and testicq of waste (see pttachnont U.>
before land application. '
�. Begin pump -out of the lagoon when fluid level rcaches cleva-
�iun 52.3 as warked by permar. e/,t warkers. Stop Pufp-out �vi»er:
the fluid level reaches elevation 50,0 or befc-e fluid dep'h is
less than 6 feet deep (this prevents the loss of favorable
hacteria) .
4. The recommended maximl,m amount to apply per irri3atioo is
one I) inch and the recomnended maximum a;plicatino e is
�nc� �er hour.
3. Keep vegetation on thc embankment and areas adjacent to the
�agcvr mowed Ye!�etation shuuld be frrtilize�
to maintain a vigorous stand.
any eroded areas or are�as damaged by rodents and
esI:ablish in vegetati»n.
7. All surface /`�nuff is tu be di;erted frum the lagoon to stable
cytl»ts.
8. The Clean Watcr Act of 1977 prohibits the discharge of
pollutants into water-_ of the United States. The 3ppa��mpnt of
Environment, Health, and Natural Res"orceE., Division �,f Exvi,`on-
wental Management, has the responsibility fcr enforrio� this law,

3peralor:5100 track 2cultv: DupliC
Distance to nearest residerue (other than owner):
1. STEADY STATE LIVE WEIGHT
0 sow; (farrow to finish)
0 Bows (farrow to feeder-)
0 head (finishing only)
0 sows (farrow to wean)
040 head (wean to feeder)
02/2_ __.
2000.0 feet
A 1417
lbs. '.
A 522
1 bs. _
x 135
lbs. _
.. 433
lbs.
x 30
lbs. _
TOTAL STEADY STATE LIVE WEIGHT (SSLW) =
_. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 91200 lbs. SSLW x Treatment VolumeiCF)/lb. SSLW
Treatment Valume(CF)/lb. SSLW=: 1 CF/lb. SSLW
Vol•.rme = 91200 cubic feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
tl oT co M9�L7 tD A-n I,awoWu EPr RF9ktSf,,J(4e e. �'n c.
UM0 '&0 Al N£29r.0-
4. TOTAL DESIGN VOLUME
Inside top length
170.0
feet q
Inside top
width
100.0 feet
Top of dike at elevation
54.0
feet,
Freeboard 1.0 feet
j Side
slope
3.0 :
I (Inside
lagoon)
Total design lajoo5
liquid
level at
elevation.
53.0 feet
Bottom of lagoon elevation
42.0
feet
Seasonal high water
table elevation
47.0 feet
Total design volume
using prismoidal
formula
SS;END1 EXER92
SS/SIDE!
SS/SIDES
LENGTH
WIDTH
DEPP.
3.0 3.0
3.0
3.0
164.0
134.0
11.0
AREA OF TO
LENGTH * WIDTH =
164.0 134.0:
AREA OF BOTTOM
LENGTH * WIDTH
99.0 68.0
21976.0 (AREA OF TOP)
6664.0 (AREA OF BOTTOM)
AREA OF MIDSECTION
LENKH * WIDTH * 4
131.0 101.0 52924.0 (AREA OF MIDSECTION *.4)
CU. FT. = [AREA TOP + (4*AF.EiA MIDSECTION) + AREA BOTTOM] * DEPTH/6
21976.0 52924.0 6664.0 1.B
VOLUME OF LAGOON AT TOTAL DESIGN LIQUID LEVEL = 14950 =T.

0
TEMPORAGN STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length } Width =
170.1 140.0 23800.0 square feet
Buildings '.roof and lot water)
_ength e width =
0.0 0.0 0.0 square feet
TOTAL DA 23600.0 square feet
Design temporary =_torage period to be
180 days.
5A.
Volume of Waste produced
Approximate daily production Df manure in
CF/LB SSLW 0.00136 .
volume = 91E00 Lbs. SSLW r CF of Waste/Lb./Gay
A 180 day.
_
'volume = 22272 cubic feet
5B.
Volume of wash water
This. is t`.e amount of fresh water used for
washing floors or volume
of fresh water used for a flush system.
Flush systems that recirculate
the lagoon water are accounted for in 5A.
volri = 0.0 gallons/day +
180 days storage/7.40 gallons
per CF
VoluvC = 0.0 cubic feet
5C.
Volume of rainfall in excess of evaporation
Use period of time when rainfall ev_eedi
evaporation by largest amount,.
180 days excess r-ainfall =
7.0 inches
volui e = 7.0 in I DA 1 _._ inches per
foot
Volume = 13883.3 cubic feet

5.r.' -lit'r':me cr 2*5 y a - --4 1.nt.ir storm
Fo1:'.me = 7.5 inchce. / 12 .,aches per- fact + CA
`lol.me = 14375.0 c-.tbic feet
TOl i!_ REQUIRED TEM"ORARY STORAGE
SA. c272 cubic feet
`_B. 0 cubic feet
5C. 13883 cubic feet
5D. 148i5 cubic feet
TOTAL 51030 cubic feet
SUMMARY
Total required volume 142230 cubic feet
Total design. volume avail. 149534 cubi•_ feet
i in. re:;. treatment volume plus sludge azcamtlatior: 912'D�e? c!:bic ,eet
O.
At elev. c"=':"feet ; ti011-kPIe is 91328 cubic feet (end p--,roping?
Total design volume less 25yr-24hr storm is 134659 cubic feet
At elev. €.L_. 3-feet ; S'clurie is 134585 cubic feet (start p•.tmpinc•
Seeaonal high water, table elevation 47.0 feet`
-VtDESIGNED BV: Q / Eli IG�R.OVED BY: t
DATE: 3C�/1-�'92- DATE: y-13-91-
!d"TE: -E- ATTACHED WASTE UTILIZi TIOt2 FLA^!

SF'ECIFICAT IOP:S FOF. CONS-! F:UFT I C'N rIF" Wi'ISI TRl31?TMIF!il IIri(_
+-fearing:
All trees and br'Ush -:hall be removed from the cor-n=:tr'uc:t*u,n area
before any excavat_.ng or fi): i=_ st,arted. '_t:tnp= .<i.li :e r,-mov. lj
wit;-,i*-: ttie area of the foundation of the embankment arid fill area.
and all excavated areas All st,_.mps and roots eyceeding �,oc ill
inch in diameter shall be removed to a 91inimum depth of erne (Ii
foot. Satisfact or:y disposition will I_e mad(? of all dobrishe
foundation area shall be loosened thoroughly before plac'eme'nt: of
enbankment material.
Cut-off Trench:
A cut-off trench (when specified) shall be installed as shown in
the plans.
CcrIstr!tction1:
Ccrlstt-uc'tion of excavated and earthfill areas shall be performed to
the neat lines and grades as planned. Deviations from this will
require prior approval of the SCS. Ear-thfill shall not be placed
in standing water- and reasonable compaction of the fills shall be
performed by the construction equipment or sheeps-foot roller-' durir1g
placement. The embankment of the la-;oon shall be installed using
the more impervie+_Is materials. Construction of.fill heights shall
include ten (10) percent for settlement. To protect againc_t secpi�kgE',
when areas of unsuitable material are encountered, they will need to
be excavated a. minimum of one (1) font below grade and backfilled e.nd
compacted with a suitable material (ie-CL,SC,CH). Refer to the soil'_.
investigation information in the planes for special cons id-r.ati�n=_.
Precautions should be taken during corist.ruction to prevent exec—c- ve
ere sier: and sedIMerttac.i'In. ..
Vegetation:
All exposed embankment and- other bare constructed areas shall be
seeded to the pl.anrood type of veget: tion as soon as possible aFtt%r..
construction.

BLEW! NG WECQMMFNV;A 3 QNa
Q%n TO FE SEEDE07 2.0 HQKL>
WE! 1KE SEED MIXTURE 1NDICATED,.
,tea FESCUE GRnss @ 6o kss. jscm.--,
(BEST SU17ED ON C.AYFY ON WET SOIL LONDIIIONS)
SEE01NO UhrEs: svPTEN6ER 15 TO NOVEMPER 10
0 1135. 'QENSnC0LA' BAHIA BRAST & SO LBS./ACHE
KSEE FCOTNOTE 40. 1)
SEEDING DATES: MARCH 15 TO JUNE 30
16 S. HULLED BERMUDA GFOSS 5,8 LBS./AC.
(SUITED FUR MOST SOIL CONDITIONS)
SEEDING DATES: APRIL 1 TO JULY 31
60 LBS. RYE SRA1N A 30 Lbb./ACRE &NURSERY FOR FESCUE)
0 LBS. RYE GRAER @ 00 LES./nCRE (TEMPORARY VEGETOTIPQ
SEEDING DATES: DECEMBER I TO MARCH 30
APPLY THE FOLLOWING:
polo LUS, OF !0-13-10 FERTILIZER E1000 L13.1ACRE)
,TONS OF OOLOMITIC LIME 12 TONS/PCRE)
200 BALES OF SMPLL GRAIN STRAW (100 BALESfACRE)
ALL SURFACE DRnlhim 5HLULD BE !N:TALLhD PRIOR TO PKED1,0. t,!!r
ALL DISFURBED AREA 1MMEDIATELYAFTER EARTH MOVING IS CuMmolow.
APOLY LINE AND FERTILIZER THEN DISK TO PREPARE A 3 TO A :101!
SMOOTH SEEDBED. APPIY SEED AND FIRM SEEDBED WITH A CHLTJPPWAErP
QR AIMILAR EQUIFTENf. APPLY MULLH AND SECUPE WITH n MUL04
PA�HJRINQ TDOn OR NSTAING.
1. PENSACOLA BPHIAGRA23 IS SLUNER 0 EQTPbLILF THAN CWQA�
BERMUDA GRAST, WHEN USING BAHIA, IT IS RECCMMEMDEC THPT 3
LKS.YACRE LF COMMON BERFULA HE iNCLUDED TO PROVIOE COUP:-,
UNFIL BAHIASRmSS 15 ESTAPLISHED.

71
im
73
14,
J'i
jf
is

I
c
at
I
IL
N
�Tj
..
.. j
0

TYPES OF MATERIAL ENCOUNTERED IN BORINGS
(Use one of systems below)
UNIFIED CLASSIFICATION
USDA CLASSIFICATION
GW-Well graded gravels; gravel, sand mix
g-graver - -
GP -Poorly graded gravels
s-sand
GM -Silty gravels; gravel -sand -silt mix
vfs-very fine sand
GC - Clayey gravels; gravel -sand -clay mix
sl-sandy loam
SW -Well graded sands; sand -gravel mix
fsl-fine sandy loam
SP-Poorly graded sands
I. -loam
SM-Silty sand
gl- gravelly loam
SC -Clayey sands; sand -clay mixtures
si-silt
ML-SiIts; silty,v. fine sands; sandy or clayey siIt
sil- silt loam
CL- Clays of low to medium plasticity
cl-clay loam
CH - Inorganic clays of high plasticity
sicl-silty clay loam
MH-Elastic silts
scl-sandy clay loam
OL-Organic silts and silty clays, low plasticity
sic -silty clay
OH -Organic clays, medium to high plasticity
c-clay
1. Suitable material for emban)tment is available O Yee O No (Indicate who. torate+t on the sketch on
. W.1
REMARKS:
2. Explain harsrds requiring special attention in design fSeeyaae, +n+tw...ock erU
GENERAL REMARKS: �;� .. ....;Tn. alp. :;'•:;- ..r c r=._..r;" /. -
24
25
26
27128129
30131
32
33
3d
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51

U: S. Department of Agrii ulture
Soil Conservation Service
NC-ENG-34
September 1980 i
File Code: 210
HAZARD CLASSIFICATION DATA SHEET FOR DAMS
landowneCounty 04ji.
Community or Group No. P(E -[fl Conservation Plan No.
Estimated Depth of Water to Top of Dam (,-. Ft. Length of Flood Pool Ft.
Date of Field Hazard Investigation 13.-11-911-
Evaluation byoreach of flood plain downstream to the point of estimated minor effect
.from sudden dam failure.
Est. Elev.:Est. ETevatlOn
Kind of :Improvements: of Breach
Reach: Length: Width: Slope: Land Use Improvements flood Aboveain::Floodwater
Above
Flood ain
Ft:. . Ft. % Ft. Ft.
1
2
3
Describe potential for loss -of life and damage to existing or probable future downstream
improvements from a sudden breach � 30o f+ -Ala +�'6 -in 0-e- G,C,f
br n,'. -4 o D Nc 1
Hazard Classification of Dam (a, b, c) (see NEM-Part 520.21)c,
Dam Classification (I, II, III, IV, V)
Concurred By n
name title
NOTE: 1. Instructions on reverse side.
2. Attach additional sheets as needed.-
Date 4-1--1?2-
Date

SCS-ENG-538
K., 5-70
U. S. DEPARTMENT Of AGRICULTURE
SOIL CONSERVATION SERVICE
SOIL INVESTIGATION TO DETERMINE SUITABILITY OF PROPOSED POND SITE
FARMER'S NAME C-r4-5 J3rb�k- DISTRICT
• . .
.•
WATERSHED AREA MEASUREMENTS
CROPLAND -ACRES —ACRES PASrURE—ACRES
■■■■■■■■■■■■
■■■■■■■■■■■■■
■■■■■■■■■■■■■■■■■■■■■■■■■■
■
■
■■■I■■■■■■■■■■■■■■■ONE
■■■■■■■
■■■■
■■■■■■■■■■■■■
■■■■■■■■■■■■_■■■■■■■■■■■■■
■■■
MEN
■■■■■■■■■■■■■■■■■■■
■■■■■■■■■■■■■■■■■■■■■■■■■■
■■■■■■■
■■�■■■■■■■■■■■■■■
■■■■■■■■■■■■■■■■■■■■■■■■■■
EMU"Q©M,ioinaim�mi©im1MIMMIMIMM100101©
■i
■!■!■!■!■!■■.■!■jai■■!■!■i■i■■!■i■i■i
I HIRING 1 l SIGNATURE& M-LE (I4t P.Tur
-� seacaA,l HCgti �Aa,i-rr-1�,b1�

IV. 4=KWjCV.
2 .81
CONSERVATION PLAN MAP
Owner —.00perator 50.�P_
Count
State _N 11 Date S-M7_ - �
Approxi;ma; �eacres Approximate scale A OT(,(0,
Cooperating with _l Ql.. 4;0•\ 4 0'Ar-e- t Conservation District
Plan identirlipation T-?I Za H --Photo number IN Ascs - 1991 K -7-
IT Assisted by oss Mic"Isne, USDA Soil Conservation Service
I
87

Ins, oa'°d rummorsvill'
Liddell
J _
IWt� r5 \
9U \Germ
remz
1.0
�`Gradys Crossroads: ••
.,gym41.5
.
IsZ
\._/\
i5u ti4 _., a
a.
outlaws Bridge �,,.. z• ��_ < '.,/ - '
_ R• eir�r yu
2 !
j J
1 �
1� k
.out
1305 d. Le a � � - , y . _ F � •. �i53!) r 'ij_ J f :,, �—�. /%'. /EI L . - \ .. �`— _, _.. a
V1 50 °42 �A1vEarsom rs am °43 • (ALSERTSONI 244
000 FEET 140 �••
Sl5° RI SE
the Geological Survey. _ SCALE 1:24 000
lorth Carolina Geodetic Survey 1 -.5_ 0 KILOMETERS (• I
t000 0 METERS f000
3m aerial photographs + 1 .5 0
edited 1980 "y� MILES
h Carolina coordinate OR 1000 s 1000 2000 0000 4000 _ 5000 0000
11 FEET
h
,rid, zone 18 1z< 1IL51� 1.37' CONTOUR INTERVAL 2 METERS

i
' ti
n x r
O .
i
L�
a
3
k\
1L
I
CG`
z -mirk-
%yJ 1
i
n
n�
,

W;*G"F I;T I1-1 ZiITluI
FOR
Stan)ey Rr`!acF.
R1; e. 1 bo,c 1 C4-C
Giber-t con YJC
hlart:h 1, 1594
•r'I waste utiIia::gti.orl plan -Ias been specifically
developed for yoa.tr c2,5It1 TOMS F'L:iULrRI' oper'atic.n.
The plan is based On I:he soil s tYI ;er Crops
_ to be grown, :-•.n,:;
method of applicat:iori for your- part,icLgar operation. TYie waste
must be land applied at a _.pec'ified rate to prevent polluL iorl
of surface and/or, groundwater. The plait. nkttr'ierlt�- if-, t:he
animal waste cho+_11d be used to reduce the amo,_tn+: of
cOmmercial
fertilizer required for' the crops in the fields where the wac.te
is to be applied. This w. _te ,_rtilizator. plan �I.ses r.itrnyen as
the limiting 1111t'r'lelit, haste should be analyzed be-iprE! eaCh
applicat:i•_rI and anm_ta] Soil tc-5ts are-mncou!. ;aye-c; so tY`d•.
plant nutrients and lime can be balanced for realistic •yie'ld
of the crops to be grown.
Several factors are important in implementiny yoI.1r, waste
utilization plan in order to maximize the fertilizer value
of the waste and to ensure that it is applied in an environ-
mentally safe manner. Always apply waste based on the ne.>ds
of the crop to be grown and the nutrient content of the Waste.
the r.mount of available nitrogen For plant Ijse is dependant On
the rcethod of application. Soil type is important dI_te to
different leaching potential and yield potential. haste -ih;:I
not be applied to land eroding at greater, than _ tons Per- acre
Per year. Do not apply waste on saturated soils or on land
when the surface is frozen. Either of these conditions may
result in r'I_uloff to s!,. t,race waters, l-)ind conditions should
also be considered to avoid drift and downwind odor problems.
To maximize the vall_te c•f 1.11e nutrients for' ;_'rep production and
reduce the potential for pelll_ttio*r, waste should be applies_ tr:
a grotving crop or not .:vvr- than days prio?- :c•
Soil incorporation of the waste will conserve nutrients and
reduce odor problerr,s.
The acres needed to apply the animal we.ste are based or,
typicalnutrient conter':t ror this type of facility. Aron -tar
acreage requirements may be mOrc• or less del"
el'Idilly al'I the
specific waste analysis report for, your facility at tie tune
of ir•riyatiorl.

YGur Wa.Ste �_ttiliz,atjon 1. is based , ti. -�e fGliv:•iini :
TABLE AMOUNT OF WPS T E Pf?i:++Ctl_rEla PER I'?fiR
--- — ---- --- -- -- ----- — ----------- ----
I NUMBER, OF I I TONS WRITE PER 1
I f1N1P1fit_S I TYPE OF ANIMALS
1 22750 1 TOMS I c_-'ol'•. `
-----------------------------------------------------
TABLE B. SUMMARY OF CROPS BY FIELD
I TRACT
I FIELD
I SOIL I ACRES I CROP,
--I-------I---------------------- --- --------I---------;
ICROPCOC;::
I---------I-------I----
1 2093
1 c
1 RaA 124.17 1 CORN
1 2093
1 3
1 RaA 149.92 1 CORN
I CO I
1 2093
1 4
1 RaA 156.51 1 CORN
I CO i
I 2093
1 9
1 RaA 19.42 1 CORN
Cf--I
TABLE C.
SUMMARY
OF CROPS, YIELD, AND NUTRIENT REQUIREMENTS BY
SOIL
------------------------------------------------
I CROP
ISOILIYIELD IUNITS iI'OTAL Ni TOTi;_ F,
I ----- I ------- I ----------
. PTO"CCiL `-. 1
I ----------- ;
1----------------------------
I CORN
I ---- I -----
IRaA 1135 IBU 1168.75 10
160 — so I
----------------------------------------------
ae Total
phosphate
and potash amounts should be confi'rred with :i
soil +est
TABLE D. WASTE MANHGEMENT BY FIELD
I
i I
CROP I tJi:6TE
Ar-'F'L I TYPE I WASTE N I
I TRACT
IFIELDI
CODE;
METHOD
I WASTE I
I ------- I
LB/AC I
--------- I
I—------I-----I-----i----------
1 3
1 1
CO
I SOIL
INC
IF'OULTRY 1
168. 75 ;
12053
i v I
CO
ISUIL
INC
IF'OULTR'r I
163.75 J
12093
1 4 1
CO
ISOIL.
INC
IPOULTRYI
168.75 1
1 2091
! 9 I
CCI
;SOIL
I tIC
I PCIULT RY 1
168.75 1
COMM N I TO APPL`r
LB/AC ;
ANINAL
WASTE
0 I
M.r'R Li
TO
JUfwE
r r.-+
0 1
MARCH
TO
JUNE I
0 1
tdi; RC!'
TO
JUNis I

The acres, crops, and application method shown in the tai.ii"_ :)i.1
accommodate approximately ;_'7'5 1. a.rri.tllals of tF-re type showy, IP Tati E!
If,mor`e commercial fertili-zer- is 1.1sed than is show-n in TaL-Ie , to n
additional acre= of land will be needed. A 10 - 25- feet: wide permanent
grass filter strip should be seeded along all ditches in field: thoa-
receive animal waste.
The acres sho:•rr, in Table N are the uc•able acres in the field shown. tJe:._,ble
acres Ar`e the acres that must be able to receive animal waste. Buffer -areas
along ditches, houses, property lines, etc. have been subtracted from
total field acreages to arrive :At the usoble .,cues. The total acres sl_:gin
on the attached map is needed for- land application in order, to have the
proper, buffer areas. R combination of land application equipment or,
irrigation equipment may be needed in order to properly land apply writ., tc-
all parts of the fields listed. It is the responsibility of the pr_d_Ic-=; to
acquire whatever, equipment is needed to properly land apply the waste.
rerODYMORMIN
prepared by: _�� —_ ---- T.it I G.f
ConcUt"r`ed in by: C - --- Date 2
Froduc -r

US Department of Agriculture
Soil Conservation Service
ENVIRONMENTAL EVALUATION
Land
NC -CPA 16
4-92
Location/Tract & Field NumberT--71aoY R11 �:elds Acreage 28.1
Prepared by:l�� Date t-11- 92_
Brief Description of Planned Practice/RMS/Project Measure:
e
Environmental Factors and Resources to Identify and Evaluate
1. Is wetland included in the planning area: (References: NCPM;
190-GM 410.26; Hydric soils list; Classification of Wetlands and
Deevwater Habitats of the U.S.; National Wetlands Inventory Maps;
NFSAM.
No
Yes - If yes,
-- Identify types present
-- Attach environmental evaluation showing what effect
planned assistance will have on wetland and how this
assistance is within policy
-- Have needed permits (LAMA, DEM, Corps, etc.) been
obtained by the landuser?
-- Make sure no planned practices will put the landowner in
violation of Swampbuster
2. Endangered and/or threatened species: (References: 190-GM
410.22; Technical Guide Section I-i(13) and Section I-vii
No Yes
-- Identify species whose range and habitat needs indicate
they might occur in planning area
-- Identify on map any designated critical habitat

3. Is a designated natural or scenic area included in the planning
area or will planned actions impact on an adjacent natural or
scenic area? (References: 190-GM 410.23 and .24)
✓ No
Yes - If yes, encourage landuser to consult with concerned
agencies, societies, and individuals to arrive at
mutually satisfactory -land use and treatment.
4. Does the planning .area include the 100-year flood plain?
(References: NCPM; 190-GM 410.25; HUD Flood Plain maps)
No
Yes - If yes,
-- Is the assisted action likely to have significant
adverse effects on existing natural and beneficial
values in the flood plain?
-- Is there a practical alternative outside the flood
plain?
-- Has the flood plain been used for agricultural
production for at least 3 of the last 5 years?
5. Is an archaeological or historical site located in the planning
area? (References: NCPM; 420-GM 401; National Register of
Historic Places)
I
Yes - If yes, have steps been taken to ensure the
protection of this area?
6. Are there any prime, unique, or locally important farmlands in
the operating unit? (References: 310-GM)
/ No
Yes - If yes, identify on a soils map or legend.
7. Will the action result in sodbusting?
✓ No Yes
8. Will the action result in swampbusting?
No
Yes
9. Is there a potential for controversy? From whom?
✓ No Yes -

10. Are permits required?/Should the person contact permit agencies?
No
Yes
J When an environmental factor or resource is identified on the
site, the user will refer to the appropriate reference for policy
and document the appropriate action in the notes portion of this
form.
NOTES, DOCUMENTATION, FOLLOW-UP

S
#
° 3a1
2
.381
3
°aqi
S
°
.
9
='/p,l
W e4ecl Acres
Y,
3. I a X 50 -
94'1. 30
15��. 00
906. 30 �A
30
p +'� of, to 7
7/. 97#1Y

m2i
1 (21 )
oO -� " i- I

Zone &K-95,
3 • 381
5 o a9I
• � o. a91
a91
c�,
C Y25
I
x 255 = 578.5T
x
v

/OF
7211
A-.
M- P

.Nanu-re from Pits
PSkFCD
LIVESTOCK WASTE SAMPLING, ANALYSIS, AND CALCULATION OF LAND APPLICATION RATES1
I. SAMPLE COLLECTION
A. Liquid Manure Slurry
1. Under -slotted -floor pit
a. Use a length of 112" conduit open on one end and that can be
easily sealed on the other end (e.g., by placing one's thumb
over the end of the conduit).
b. With both ends of the conduit open, extend it into the manure
to the pit floor.
c. Seal the upper end of the conduit trapping the manure that has
entered the lower end, remove and empty into a bucket or container.
c. Collect samples from at least 5 locations or at least enough
for a total of 1 quart of slurry.
e. Thoroughly mix this slurry and empty approximately 112 pint
into sample container.
2. Exterior storage basin or tank
a. Make sure the manure has been well mixed or homogenized with a
liquid manure chopper -agitator pump or propeller agitator.
b. Take samples from approximately 5 locations in the pit, from the
agitator pump, or from the manure spreader and place.in a bucket.
c. Thoroughly mix and empty 112 pint into sample container.
II. SAMPLE PREPARATION AND TRANSFER
A. Place the sample .for analysis into a flexible or expandable container that
can be sealed. The container should be rinsed clean with water and free
of any residues but should not be chlorinated or treated in any other way.
Dry litter may also be placed in a sealed plastic bag such as a freezer bag.
B. The sample should be refrigerated, iced or cooled, if possible, or trans-
ferred to the lab immediately.
C. Hand -delivery is the most reliable way of sample transfer, but it can also
be mailed.
D. If mailed, sample container should first be protected with a packing material
such as new then boxed or packaged with wrapping paper and taped.
E. The NCDA Plant Analysis Lab provides this service for a nominal fee of
$4 per sample which should be forwarded along with the sample.

PSWCD 1
1. Address: N. C. Department of Agriculture
Plant Analysis Lab
Agronomic Division
Blue Ridge Road Center
Raleigh, NC 27611
Ph: [phone]
Attn: Dr. Ray Campbell
F. Request that as a minimum the following analyses be performed:
1. Total nitrogen (TKN)
2. Ammonia nitrogen (NN N)
3. Total phosphorus .(TP)
4. Potassium (K)
5. Dry litter samples should also include a total solids (TS) analysis.
G. Otiier analyses performed at no extra cost by NCDA include trace minerals.

PSWCD 2
I. SAMPLE COLLECTION
B. Lagoon Liquid
1. Collect approximately 1/2 pint of recycled lagoon liquid from the
inflow pipe to the flush tanks.
2. From lagoon
a. Place a small bottle (1/2 pint or less) on the end of a 10-15
foot long pole.
b. Extend the bottle 10-15 feet away from the bank edge.
c. Brush away any floating scum or debris so it is not collected
with sample.
d. Submerge the bottle within 1 foot of the liquid surface
e. Repeat at approximately 5 locations around the lagoon, place
into a bucket, thoroughly mix, and empty 1 pint into sample
container.
3. From a multi -stage lagoon system collect sample from lagoon that
is going to be irrigated from.
II. SAMPLE PREPARATION AND TRANSFER
A. Place the sample for analysis into a flexible or expandable container that
can be sealed. The container should be rinsed clean with water and free
of any residues but should not be chlorinated or treated in any other way.
Dry litter may also be placed in a sealed plastic bag such as a freezer bag.
B. The sample should be refrigerated, iced or cooled. if possible, or trans-
ferred to the lab immediately.
C. Hand -delivery is the most reliable way of sample transfer, but it can also
be mailed.
D. If mailed, sample container should first be protected with a packing material
such as newspaper, then boxed or packaged with wrapping paper and taped.
E. The NCDA Plant Analysis Lab provides this service for a nominal fee of
$R per sample which should be forwarded along with the sample.
1. Address: N. C. Department of Agriculture
Plant Analysis Lab
Agronomic Division
Blue Ridge Road Center
Raleigh, NC 2.7611
Ph: [phone]
".ttn: Dr. .13 Campbell

PSWCD 2
F. Request that as a minimum the following analyses be performed:
1. Total nitrogen (TKN)
2. Ammonia nitrogen NH
3. Total phosphorus �TP3
4. Potassium (K)
5. Dry litter samples should also include a total solids (TS) analysis.
G. Other analyses performed at no extra cost by NCDA include trace minerals.

ANIMAL WASTE MANAGEMENT PLAN CERTIFICATION FOR EXISTING FEEDLOTS
Please return the completed form to the Division of Environmental Management-ata ad� on the
reverse side of this form. .,
Name of farm (Please print) : PIGS `R* us MAY Z 2 14;�4
Mailing Address: 42W N. N wY • 1 f f
ALPSER7 , NC 26500 Phone No.: O AB1L 40130MENT ONIT
County (of farm): "!i
Farm location: Latitude and Longitude: 35 00' 30" 7V 50' o5" (required). Also, please attach a
copy of a county road map with location iden feed.
Type of operation (swine, layer, dairy, etc.) : sw1Nr-- (wc-AV ro FerEyeR)
Design capacity (number of animals) : 3200
Average size of operation (12 month population avg.): 3200
-Average acreage needed for land application of waste— (acres) : 7 6 Agj-s
Technical Specialist Certification
As a technical specialist designated by the North Carolina Soil and Water Conservation Commission pursuant
to 15A NCAC 6F .0005, I certify that the existing animal waste management system for the farm named
above has an animal waste management plan that meets the operation and maintenance standards and
specifications of the Division of Environmental Management and the USDA - Soil Conservation Service
and/or the North Carolina Soil and Water Conservation Commission pursuant to 15A NCAC 2H.0217 and
15A NCAC 6F .0001 - .0005. The following elements and their corresponding minimum criteria have been
verified by me or other designated technical specialists and are included in the plan as applicable: minimum
separations (buffers); adequate quantity and amount of land for waste utilization (or use of third party);
access -or ownership of proper waste application equipment; schedule for timing of applications; application
rates; loading rates; and the control of the discharge of pollutants from stormwater runoff events less severe
than the 25 - year, 24 - hour storm.
When checked, see reverse side of form for conditions/exceptions.
Name of Technical Specialist (Please Print): OEov&r- N - FErrus
Affiliation (Agency): bo vsBouo NoG Fan-ms ING.
Address (Agency): F-O. SOX l 000q vowS519vto Phone No.: qia--t70-3I3o
Signature: leit, Date: fµ may 0
Owner/Mananer Agreement
I (we) understand the operation and maintenance procedures established in the approved animal waste
management plan for the farm named above and will implement these procedures. I (we) know that any
expansion to the existing design capacity of the waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the Division of Environmental Management
before the new animals are stocked. I (we) also understand that there must be no discharge of animal waste
from this system to surface waters of the state either directly .through a man-made conveyance or through
runoff from a storm event less severe that the 25-year, 24-hour storm. The approved plan will be filed at the
farm and at the office of the local Soil and Water Conservation District.
Name of Land Owner (Please Print): '6TANLE`f Curaft5 FA7.061c
Signature: Date: u+ mA-4 -16
Name of Manager, if different from owner (Please print):
Signature: Date:
Note: A change in land ownership requires notification or a new certification (if the approved plan is changed) within 60 days of a title transfer.
DEM USE ONLY: ACE# Z:Oo /u 3

= CONDITIONS AND/OR EXCEPTIONS TO CERTIFICATION
All statements checked apply to this certification:
The installed irrigation system has not been evaluated concerning nozzle size, spray pattern, spacing, pump size, pipe size,
etc. It is the responsibility of the producer to operate the system with the proper components and to supply the required
maintenance to assure that no runoff occurs. The producer is encouraged to have an irrigation specialist, possibly the dealer
where the system was purchased, prepare an operation and maintenance plan for the irrigation system so that the producer
knows how to operate the equipment to meet the non -discharge requirements.
The waste management.plaa for this operation is based upon yields higher than what is now recommended by NRCS;
however, tbeseyields are obtainable under high levels of management. This increase in projected yields is necessary since
the NRCS plan prepared for this operation at the time of construction was based upon these higher yields and the producer ,
followed IVKW guidelines when building this operation. .
Because of limited acres for land application, and because the original NRCS waste utilization plan did not require
additional acres for buffers and irrigation inefficiency, it may be necessary for the producer to operate half sprinklers, on
solid set systems, along field edges and ditches. Also for trave4ng irrigation systems, a pull directly adjacent to the ditch with•,
only a 180 degree pumping radius may be needed to irrigate the entire field. Extreme caution should be exercised when
applying waste close to ditches and wetlands to avoid any discharge.
CERTIFICATION FOR EXISTING FEEDLOTS
INSTRUCTIONS FOR CERTIFICATION OF APPROVED ANIMAL WASTE MANAGEMENT PLANS FOR EXISTING ANIMAL
WASTE MANAGEMENT SYSTEMS SERVING FEEDLOTS
REQUIREMENTS/PURPOSE
In order to be deemed permitted by the Division of Environmental Management (DEM), the owner of any existing animal waste
management system constructed and operational before January 1, 1994 which is designed to serve greater than or equal to the animal
populations listed below is required to submit a signed certification form to DEM before January 1, 1998. Pasture operations are exempt
from the requirement to be certified.
100 head of cattle
75 horses
250 swine
1,000 sheep
30,000 birds with a liquid waste system
The certification must be signed by the owner of the feedlot (and manager if different from the owner) and by say technical specialist
designated by the Soil and Water Conservation Commission pursuant to 15A NCAC 6F .0001-.0005. The technical specialist must verify
that all applicable operation and maintenance standards and specifications can be met. Existing systems are not required to meet design
and construction standards and specifications.
Although the actual number of animals on the facility may vary from time to time, the design capacity of the waste handling system should
be used to determine if a farm is subject to the certification requirement. For example, if the waste system for a feedlot is designed to
handle 300 hogs but the average population will be 200 hogs, then the waste management system requires a certification.
This certification is required by regulations governing animal waste management systems adopted by the Environmental Management
Commission (EMC) on December 10, 1992 (Title 15A NCAC 2H .0217).
CERTIFICATION FORM
On the reverse side of this page is the certification form which must be submitted to DEM before January 1, 1998. Assistance in
completing the form can be obtained from one of the local agricultural agencies such as the Soil and Water Conservation District, the
USDA -Soil Conservation Service, or the N.C.. Cooperative Extension Service. The Completed form should be sent to:
Department of Environment, Health and Natural Resources
Division of Environmental lklanagement
Water Quality Section, Planning Branch
P.O. Box 29535
Raleigh, NC 27626-0535

l R�21
.mom 'O

Emergency Action Plan
This plan will be implemented in the event that wastes from you operations are leaking, overflowing,
or running off the site. You should NOT wait until wastes reach surface waters or leave your
property to consider that you have a problem. You should make very effort to ensure that this does
not happen. This plan should be available to all employees at the facility, as accidents, leaks, and
breaks can happen at any time.
1) Stop the release of wastes. Depending on the situation, this may or may not be possible.
Suggested responses to problems are listed below:
a) Lagoon overflow:
• add soil to the berm to increase the elevation of the dam
• pump wastes to fields at an acceptable rate
• stop all additional flow to the lagoon (waterers)
• call a pumping contractor
• make sure no surface water is entering the lagoon
Note: These activities should be started when your lagoon level has exceeded the temporary
storage level.
b) Runoff from waste application field:
• immediately stop waste application
0 create a temporary diversion or berm to contain the waste on the field
• incorporate waste to reduce further runoff
c) Leaking from the waste distribution system:
• pipes and sprinklers:
© stop recycle (flushing system) pump
® stop irrigation pump
© close valves to eliminate further discharge
® separate pipes to create an air gap and stop flow
PROP t

• flush system, houses, solids separators:
(D stop recycle (flushing system) pump
® stop irrigation pump
© make sure no siphon effect has been created
® separate pipes to create an air gap and stop flow
d) Leakage from base or sidewall of the lagoon. Often these are seepage as opposed
to flowing leaks:
• dig a small well or ditch to catch all seepage, put in a submersible pump, and
pump back into the lagoon
• if holes are caused by burrowing animals, trap or remove animals and fill holes
and compact with a clay type soil.
• other holes may be likewise temporarily plugged with clay soil.
Note: For permanent repair measures, lagoon problems require the consultation of an individual
experienced in their design and installation.
2) Assess the extent of the spill and.note any obvious damages.
a) Did the waste reach any surface waters?
b) Approximately how much was released and for what duration?
c) Any damage noted, such as employee injury, fish kills, or property damage?
3) Contact appropriate agencies.
a) During normal business hours, call your DWQ regional office: 910-395-3900. after hours,
emergency number: 800-858-0368 or 919-733-3942. Your phone call should include:
your name, facility, telephone number, the details of the incident, the exact location of the
facility, and the location or direction of movement of the spill, weather and wind
conditions, what corrective measures have been taken, and the seriousness of the
situation.
b) Your integrator: Goldsboro Hog Farms Division, Maxwell Foods, Inc.
919-778-3130 extension 1430
c) If the spill leaves the property or enters surface waters, call the local EMS:
910-296-2160 .

d) Instruct EMS to contact the local Health Department: 910-296-2126.
e) (For technical assistance)
Contact CES: " 910-296-2143
Local NRCS office: 910-296-2121
4) Implement procedures as advised by DWQ and technical assistance agencies to rectify the
damage, repair the system, and reassess the waste management plan to keep problems with
release of wastes from happening again.
5) Contact contract pumping and/or irrigation equipment companies:
6). - Contact dirt moving and/or heavy equipment companies:
duplin
A
R
Pnov Z

0
Swine Farm Waste Management Odor Control Checklist
an
Q Recommended best management pracuccs
(9 Good judgment and common sense
floors
Mr Slotted floors;
O' Waterers located over slotted floors;
❑ Feeders at high end ofsolid floors;
9' Scrape manure buildup from floors;
❑ Underfloor ventilation for drying
❑ 17 ucnt manure removal by flush. Pit recharge,
pits • urine; q
• Partial microbial decomposition or scrape;
❑ Underfloor ventilation
Ventilation exhaust tans • vmautc gu�ca,
Dust
liquid while tanks are filling
Flush alleys • Agitation during wastewater
conveyance
Pit recharge points • Agitation of recycled lagoon
liquid while pits are filling
Lift stations • ,Agitation during sump tank
filling and drawdown
Outside drain collection • Agitation during wastewater
or junction boxes conveyance
CAI' Fan maintenance;
Ca' Efficient air movement
(a Washdown between groups of animals;
O' Feed additives;
❑ Feeder covers; .
(3" Feed delivery downspout extenders to feeder
etwer9
❑ Flush tank covers;
13' Extend fill lines to near bottom of tanks with
anti -siphon vents
❑ Underfloor flush with underfloor ventilation
7 Extend recharge lines to near bottom of pits
with anti -siphon vents
❑ Sump tank covers
Box covers
A nett(` - 1Jnvemher 11. 1996. Page 3

Source
Cause
BMPs to Minimize Odor Site Specific Practices
End of drainpipes at
•
Agitation during wastewater
❑
Extend discharge point of pipes underneath
lagoon
conveyance
lagoon liquid level
Lagoon surfaces
•
Volatile gas emissions;
Proper lagoon liquid capacity;
•
Biological mixing;
W
Correct lagoon startup procedures;
•
Agitation
Gr
Minimum surface area -to -volume ratio;
Gr
Minimum agitation when,pumping;
❑
Mechanical aeration;
9
Proven biological additives - wke" Nam."vco
Irrigation sprinkler
•
High pressure agitation;
O'
Irrigate on dry days with little or no wind;
nozzles
Wind drift
GY
Minimum recommended'operating pressure;
9' Pump intake near lagoon liquid surface;
❑
Pump from second -stage lagoon
Storage tank or basin
•
Partial microbial decomposition;
❑
Bottom or midlevel loading;
surface
•
Mixing while filling;
❑
Tank covers;
•
Agitation when emptying
❑
Basin surface mats of solids;
❑
Proven biological additives or oxidants
Settling basiri`surfacc
Partial microbial decomposition;
❑
Extend drainpipe outlets underneath liquid
•
Mixing while filling;
level;
Agitation when emptying
❑
Remove settled solids regularly
Manure, slurry or sludge
•
Agitation when spreading;
❑
Soil injection of slurry/sludges;
spreader outlets
.
Volatile gas emissions
❑
Wash residual manure from spreader after use;
❑
Proven biological additives or oxidants
Uncovered manure,
•
Volatile gas emissions while
❑
Soil injection of slurry/sludges
slurry or sludge on field
drying
❑
Soil incorporation within 49 hrs.;
surfaces
❑
Spread in thin uniform layers for rapid drying;
❑
Proven biological additives or oxidants
pits
* Proper dispositionofcarcasses
❑ Complete covering of carcasses in burial pil
❑ Proper location/construction ofdisposal pits
Secondary stuck burners
AMA" - November 11, 1996, Page

facilities
Improper drainage;
Microbial decomposition of
Gr Grade and landscape such that water
away from facilities
organic matter
Manure tracked onto • Poorly maintained access roads Gr Farm access road maintenance
public roads from farm
access
Additional Information :
Swine Manure Management; 0200 Rule/BMP Packet
Swine Production Farm Potential Odor Sources and Remedies; EBAE Fact Sheet
Swine Production Facility Manure Management: Pit Recharge - Lagoon Treatment; EBAE 128-88
Swine Production Facility Manure Management: Underfloor Flush - Lagoon Treatment; EBAE 129-88
Lagoon Design and Management for Livestock Manure Treatment and Storage; EBAE 103-83
Calibration of Manure and Wastewater Application Equipment ; EBAE Fact Sheet
Controlling Odors from Swine Buildings; PIHr33
Environmental Assurance Program; NPPC Manual
Options for Managing Odor; a report from the Swine Odor Task Force
Nuisance Concerns in Animal Manure Management: Odors and Flies: PRO107, 1995 Conference Proceedings
Available
NCSU -BAE
NCSU-BAE
NCSU-BAE
NCSU-BAE
NCSU -BAE
NCSU - Swine Extension
NC Pork Producers Assoc
NCSU Agri Communications
Florida Cooperative Extension
AMOC - November 11, 1996, Page 5.

Insect Control Checklist for Animal Operations
sufficiently to remove accumulates sottas From
gutters as designed.
O Remove bridging of accumulated solids at
Lagoons and Pits • Crusted Solids Let' Maintain lagoons, settling basins and pits where
pest breeding is apparent to minimize the
crusting of solids to a depth of no more than 6 -
8 inches over more than 30% of surface.
Excessive Vegetative • Decaying vegetation W Maintain vegetative control along banks of
Growth lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along watees edge on impoundment's perimeter.
• Feed Spillage O Design, operate and maintain feed systems (e.g.,
bunkers and troughs) to minimize the
accumulation of decaying wastage.
a Clean up spillage on a routine basis (e.g., 7 - 10
day interval during summer; 15-30 day interval
ucs O Reduce moisture accumulation within and
around immediate perimeter of feed storage
areas by insuring drainage away from site
and/or providing adequate containment (e.g.,
covered bin for brewer's grain and similar high
moisture grain products).
O Inspect for and remove or break up accumulated
solids in filter strips around feed storage as
needed.
AMID - November 11, 1996, Page I

Source Cause BNW5 to Control Insects- bite specutc rracuces
Areas • Accumulations of animal wastes
and feed wastage
O Eliminate low areas that trap moisture along
fences and other locations where waste
accumulates and disturbance by animals is
minimal.
O Maintain fence rows and filter strips around
animal holding areas to minimize
accumulations of wastes Ox., inspect for and
remove or break up accumulated solids as
Dry Manure Handling Accumulations of animal wastes 0 Remove spillage on a routine basis (e.g., 7 - 10
Systems day interval during summer, 15-30 day interval
during winter) where manure is loaded for land
application or disposal.
0 Provide for adequate drainage around manure
stockpiles.
O Inspect for and remove or break up accumulated
wastes in filter strips around stockpiles and
manure handling areas as needed.
For more information contact the Cooperative Extension Service, Department of Entomology, Box 7613, North Carolina State University,
Raleigh, NC, 27695-7613.
AMIC - November 11, 1996, Page 2

Mortality Management Methods
(check which method(s) are being implemented)
❑ Burial three feet beneath the surface of the ground within 24 hours after
knowledge of the death. The burial must be at least 300 feet from any flowing
stream or public body of water.
O Rendering at a rendering plant licensed under G.S. 106-168.7
❑ Complete incineration
❑ In the case of dead poultry only, placing in a disposal pit of a size and design
approved by the Department of Agriculture
Ca Any method which in the professional opinion of the State Veterinarian would
make possible the salvage of part of a dead animal's value without endangering
human or animal health. (Written approval of the State Veterinarian must be
attached)
December 18, 1996

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
Michael F. Easley, Governor
William G. Ross, Jr., Secretary
STANLEY CURTIS BROCK
PIGS R US INC
4220 N HWY 111
ALBERTSON NC 28508
Dear Mr. Brock:
FFB 0 Z001
February 2, 2001
A
•: '
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Application No. AWS310211
Additional Information Request
Pigs R Us Inc
Animal Waste Operation
Duplin County
The Non -Discharge Permitting Unit cannot complete a preliminary engineering review of your
application. Additional information is required before we can continue our review. Please address the
following by March 4, 2001:
1. Please provide pages 2 through 9 of your Waste Utilization Plan.
You only sent the first page.
Please reference the subject permit application number when providing the requested
information. All information should be signed, sealed, and submitted in duplicate to my attention at the
address below.
NCDENR-Non Discharge Permitting Unit (attn: Theresa Nartea)
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
The information requested by this letter must be submitted on or before March 4, 2001 or the
Division will return your application as incomplete in accordance with 15A N.C.A.C. 2H .0200 and your
facility will be considered to be operating without a permit.
Please be advised that operation of the subject animal waste management system without a valid
permit is a violation of North Carolina General Statute 143-215.1 and will subject you to the
enforcement authority of the Environmental Management Commission.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Application No. 31-0211
Page 2
If you have any questions regarding this request, please call me at [phone], ext. 375.
Sincerely,
Theresa Nartea
Soil Scientist
Non -Discharge Permitting Unit
cc: Wilmington.RegionaI Office, -Water Quality
Permit File -

State of North Carolina
Department of Environmen=BY:
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
October 23, 2000
CERTIFIED MAIL
Stanley Curtis Brock
Pigs R Us Inc
4220 N Hwy 11 I
Albertson NC 28508
Farm Number: 31 - 211
Dear Stanley Curtis Brock:
1� •WAA
A
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
You are hereby notified that Pigs R Us Inc, in accordance with G.S. 143-215.1OC, must apply for coverage under an
Animal Waste Operation General Permit. Upon receipt of this letter, your farm has sixty (60) days to submit the attached
application and all supporting documentation. In accordance with Chapter 626 of 1995 Session Laws (Regular Session
1996), Section 19(c)(2), any owner or operator who fails to submit an application by the date specified by the
Department SHALL NOT OPERATE the animal waste system after the specified date. Your application must be
returned within sixty (60) days of receipt of this letter. Failure to submit the application as required may also subject your
facility to a civil penalty and other enforcement actions for each day the facility is operated following the due date of the
application.
The attached application has been partially completed using information listed in your Animal Waste Management
Plan Certification Form. If any of the general or operation information listed is incorrect please make corrections as noted on
the application before returning the application package. The signed original application, one copy of the signed application,
two copies of a general location map, and two copies of the Certified Animal Waste Management Plan must be returned to
complete the application package. The completed package should be sent to the following address:
North Carolina Division of Water Quality
Water Quality Section
Non -Discharge Permitting Unit
1617Mail Service Center
Raleigh, NC 27699-1617
If you have any questions concerning this letter, please call Theresa Nartea at [phone] extension 375 or
Stoney Matthis with the Wilmington Regional Office at [phone].
Sincerely,
/ for Kerr T. Stevens
cc: Permit File (w/o encl.)
Wilmington Regional Office (w/o encl.)
1617 Mail Service Center, Raleigh, NC 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Plan Amendment to Include S&WCC Chronic Rainfall Practices and Standards through March 31, 2000
1. If this facility can comply with its existing permit and CAWMP it must do so.
2. Temporary Addition of New SprayfieldsIU(Check_appropriateboxes.).-
0 A. acres of cropland. List crop types used:
Q B. acres of hardwood woodland @ 100 lbs PAN / acre added.
0 C. acres of pine woodland added @ 60 lbs PAN / acre added.
3. Summer Perennial Grass (Check appropriate box.)
$A. Application window extended for NZ acres of perennial grass until first killing frost-
0 B. An additional 50 lbs of PAN applied to acres of perennial grass prior to killing frost
4.. PAN Application Increased for Small Grains & Winter Grasses to be harvested. (Check appropriate box.)
Xq, PAN application increased up to 200 lbs per acre for 6.VfZ acres of small grains or winter grasses to be harvested.
U B. PAN application increased up to ISO lbs per acre for _ acres of overseeded summer perennial included in 3. B.
5. Waste Analysis (Check appropriate box.)
0 A. Prior to December 1", 4999 the calculation of PAN will be based on a 35% reduction -of the last analysis taken
p to the firs[ 25 year 24 hour storm event. (Current waste analysis must be used after Dec.I ° .)
Use current waste analysis to determine PAN.
6. Required -Maximum Nitrogen Utilization Measures for Small Grains and Winter -Grasses.
A. Use of higher seeding rates,
B. Timely harvest of forage to increase yield, and
C. Irrigating during periods of warmer weather.
7. Required - Irrigation Management Techniques to Reduce Runoff and Ponding Potential.
A. Making frequent, light irrigation applications, and
B. Not irrigating immediately before predicted rainfall.
8.. The owner / manager is required to manage the movement of animals to and from the facility to minimize environmental
impacts, ensure compliance with the facility's permit and amended CAWMP, and avoid discharge to surface waters.
9. Authorization to use the additionalpractices included in this amendment expires if a facility discharges to surface waters.
Any discharge is a violation and may result in an enforcement action.
10. The owner / operator is required to keep records of all waste applications.
11. This revision must include a map or sketch of new land application areas.
Facility Number 3
'SAaft1XI CIkrr . s TS(O(,k
Facility Owner / Manager Name (PRINT)
Facili Owner / Manager Signature
Date )I- 17- 99
Pigs le- US
Facility Name
(sC-09& N. PErruS
Technical Specialist Name (PRINT)
chn al Specialist Signature
Date 22 tq0✓ 19
This document must be filed at the SWCD office and be attached to the.facilities CAWMP
and be available for inspection at the facility.
(*) New temporary sprayfields must meet applicable buffer and setback requirements. Waste must not be applied to wetlands.
11/11/1999

State of North Carolina 1?qC14g'4'V
Department of Environment
and Natural Resources REr� v Ltt
Y v liLI
Division of Water Quality
JAN 0 6 2000
James B. Hunt, Jr., Governor C D EN R
Bill Holman, Secretary BY:
Kerr T. Stevens, Director
Stanley Curtis Brock
Pigs R Us Inc
4220 N Hwy 11 1
Albertson NC 28508
Dear Stanley Curtis Brock:
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
December 30, 1999
Subject: Fertilizer Application Recordkeeping
Animal Waste Management System
Facility Number 31-211
Duplin County
This letter is being sent to clarify the recordkeeping requirement for Plant Available Nitrogen (PAN)
application on fields that are part of your Certified Animal Waste Management Plan.
In order to show that the agronomic loading rates for the crops being grown are not being exceeded, you
must keep records of all sources of nitrogen that are being added to these sites. This would include nitrogen
from all types of animal waste as well as municipal and industrial sludges/residuals, and commercial fertilizers.
Beginning January 1, 2000, all nitrogen sources applied to land receiving animal waste are required to
be kept on the appropriate recordkeeping forms (i.e. IRRI, IRR2, DRYI, DRY2, DRY3, SLURI, SLUR2,
SLDI, and SLD2) and maintained in the facility records for review. The Division of Water Quality (DWQ)
compliance inspectors and Division of Soil and Water operation reviewers will review all recordkeeping during
routine inspections. Facilities not documenting all sources of nitrogen application will be subject to an
appropriate enforcement action.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Ms. Sonya Avant of the
DWQ staff at [phone] ext. 571.
cc: Wilmington Regional Office
Duplin County Soil and Water Conservation District
Facility File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617
An Equal Opportunity Affirmative Action Employer
Sincere) ,
Kerr T. Stevens, Director
Division of Water Quality
Telephone[phone] Fax [phone]
50% recycled/10% post -consumer paper

JUSTIFICATION & DOCUMENTATION FOR MANDATORY WA
Facility Numb r 3 �
Farm Name:
On -Site Representative: qq�
Inspector/Reviewer's Name: '_1w_�A-j�_,_
Date of site visit:_ a a' ( h9
R-evised January 22, 1999
DETERMINATION
Operation is'f7agged for a wettable
acre determination due to failure of
Par( H eligibility ftem(s) F1 F2 F3 F4
Operation not required to secure WA
determination at this time based on
exemption El E2 93� E4
Date of most recent NVUP: Annual farm PAN deficit:
r tm_ 1`1-99 -_ pounds
Irrigation System,(s) - circle #. 1. hard -hose traveler, 2. center -pivot system; 3. Ins ar-move system;
s4. stationary sprinkler system w/permanent pipe; 5. stationary sprinkler system w/portable pipe;
tationary gun system w/permanent pipe; 7. stationary gun system w/portable pipe
PART I. WA Determination Exemptions (Eligibility failure, Part II; overrides Part I exemption.)
E1 Adequate irrigation design, including map depicting wettable acres, is complete
and signed by an I or PE.
E2 Adequate D, and D2/D3 irrigation operating parameter sheets, including map
/ depicting wettable acres, is complete and signed by an I or PE.
v E3 Adequate D, irrigation operating p g parameter sheet, including map depicting
wettable acres, is complete and signed by a WUP.
E4 75% rule exemption as verified in Part III. (NOTE: 75 % exemption cannot be
applied to farms that fail the eligibility checklist in Part II: Complete eligibility
checklist, Part II - F1 F2 F3, before completing computational table in Part III).
PART If. 75% Rule Eligibility Checklist and Documentation of WA Determination
Requirements. WA Determination required because operation fails one of the eligibility
requirements listed below.
F1 Lack of acreage which resulted in over application of wastewater (PAN) on spray
field(s) according to farm's last two years of irrigation records.
F2 Unclear, illegible, or lack of information/map.
F3 Obvious field limitations (numerous ditches; failure to' deduct required
buffer/setback acreage; or 25% of total acreage identified in CAWMP includes
small, irregularly shaped fields - fields less than 5 acres for travelers or less than
2 acres for stationary sprinklers).
F4 WA determination required because CAWMP credits field(s)'s acreage in excess
of 75% of the respective field's total acreage as noted in table in Part III.

Facility Number 3l -'a 11
Revisad Januari, 22, I c
Part Ill. Field by Field Determination of 75% Exemption Rule for WA Determination
[NUMBER
RACT FIELD TYPE OF TOTAL CAWMP FIELD COMMENTS'
NUMBER''2 IRRIGATION BORES ACRES
SYSTEM
- I h I I �.,►
9.14 1 u.S
_�� ry�mcstFz' -hydrant, pull, zone, or point numbers may be used in place of field numbers depending on CAWly
and type of irrigation system. If pulls, etc. cross more than one field, inspector/reviewer will have to combine fields to
calculate 75% field by field determination for exemption if possible; otherwis
determination. e operation will be subject to WA
FIELD NUMBERZ - must be clearly delineated on map.
COMMENTS' - back-up fields with CAWMP acreage exceeding 75% of its total acres and having received less than 5D%
of its annual PAN as documented in the farm's previous two years' (1997 & 1998) of irrigation records, cannot serve as the
sole basis for requiring a WA Determination. Back-up fields must be noted in the comment section and must be accessible
by irrigation system.

. R
WASTE UTILIZATION PLAN
Goldsboro Hog Farms, Inc.
Tuesday, May 14, 1996
Producer: Curtis Brock
Farm Name
Telephone # :
Type of Operation
Number of Animals:
Application Method:
Pigs "R" Us
4220 N Hwy 111
Albertson,NC 28508
[phone]
Wean to Feeder Swine
3200 pigs design capacity
Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface and/or groundwater. The plant nutrients in the animal waste should be
used to reduce the amount of commercial fertilizer required for the crops in the fields where
waste is to be applied. This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil tests are strongly
encouraged so that all plant nutrients can be balanced for realistic yields of the crop to be
grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
contents of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and avaialable water holding capacities. Normally waste shall not be applied to
land eroding at greater than 5 tons per acre per year. With special pre -cautions, waste may
be applied to land eroding at up to 10 tons per acre per year. Do not apply waste on
saturated soils, when it is raining, or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed under DEM regulations. Wind
conditions should also be considered to avoid drift and downwind odor problems. To
maximize the value of the nutrients for crop production and to reduce the potential for
pollution, the waste should be applied to a growing crop or applied to bare ground not more
than 30 days prior to planting. Injecting the waste or disking will conserve nutrients and
reduce odor problems. This plan is based on waste application through irrigation for this is
the manner in which you have chosen to apply your waste. If you choose to inject the waste
in the future, you need to revise this plan. Nutrient levels for injecting waste and irrigating
waste are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for ananlysis. This waste
utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H.0217 adopted by the Environmental Management Commission.
Page 1 of 9

A
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
3200 pigs X .4 tons waste/pigs/year = 1280 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
3200 pigs X .48 Ibs PAN/pigs/year =1536 PAN/year
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on the crop to be grown,
soil type and suface application.
TABLE 1 : ACRES OWNED BY PRODUCER
TRACT FIELD SOIL TYPE &CLASS. CROP YIELD LBS AW COMM ACRES LBS AW APPLIC.
DETERMINING PHASE CODE NACRE N/ACRE USED TIME
71204
2
UTRYVILLEALL
BC
4.7
235
0
3.18
747.3
MAR-SEP
71204
- 2
AUTRYVILLE ALL
SG
1.5
75
0
3.'18
238.5
SEP-MAR
71204
3
UTRYVILLE ALL
BC
4.71
235
0
2.462
578.57
MAR-SEP
71204
- 3
UTRYVILLE ALL
SG
1.51
751
01
2.4621
184.65
SEP-MAR
TOTALS: 1749.02
— Indicates that this field is being overseeded (i.e. interplanted) or winter annuals follow
summer annuals.
* Indicates a Crop Rotation
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N
requirments. Beginning in 1996 the Coastal Zone Management Act will require farmers in
some eastern counties of NC to have a nutrient management plan that addresses all
nutrients. This plan only addresses Nitrogen.
Page 2 of 9

TABLE 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land. See required specifications 2.)
There are no Acres Leased
- Indicates that this field is being overseeded (i.e. interplanted) or winter annuals follow
summer annuals.
* Indicates a Crop Rotation
* Acreage figures may exceed total acreage in field due to overseeding.
**Lbs AW N (animal waste nitrogen) equals total required nitrogen less any commercial
nitrogen (COMM N) supplied.
The following legend explains the crop codes used in TABLES 1 and 2 above:
CROP CODE CROP UNITS LBS N/UNIT
BC
I HYBRID BERMUDAGRASS-CONTROLLED GRAZED
TONS
50
SG
I SMALL GRAIN OVERSEEDED
AC
50
Page 3 of 9

TOTALS FROM TABLES 1 AND 2
ACRES LBS AW
N USED
TABLE 1 5.642 1,749
TOTALS: 1 6.6421 1,749
AMOUNT OF N PRODUCED: 1,536
" BALANCE -213
*** This number must be less than or equal to 0 in order to fully utilize the animal waste N
produced.
Acres show in each of the preceeding tables are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter
areas not receiving full application rates due to equipment limitations. Actual total acres in the
fields listed may, and most likely will be, more than the acres shown in the tables.
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of
sludge at agronomic rates. The sludge will be nurturient rich and will require precautionary
measures to prevent over application of nutrients or other elements. Your production facility
will produce approximately 243.2 pounds of plant available nitrogen (PAN) per year in the
sludge that will need to be removed on a periodic basis. This figure is PAN when
broadcasting the sludge. Please be aware that additional acres of land, as well special
equipment, may be needed when you remove this sludge.
See the attached map showing the fields to be used for the utilization of waste water.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the soil at the time of
irrigation such that runoff or ponding occurs. This rate is limited by initial soil moisture
content, soil structure, soil texture, water droplet size, and organic solids. The application
amount should not exceed the available water holding capacity of the soil at the time of
irrigation nor should the plant available nitrogen applied exceed the nitrogen needs of the
crop.
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every 5.92 months. In no instance should the volume of
waste being stored in your structure be within 1.8 feet of the top of the dike.
If surface irrigation is the method of land application for this plan, it is the responsiblity of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in Tables 1 and 2. Failure to apply the recommended rates and
amounts of Nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application rates and amounts.
APPLICATION
APPLICATION
TRACT FIELD SOIL TYPE
CROP
RATE (INhr)
AMT (inches)
i71204
-2,-3
UTRYVILLE ALL
SG
1 0.60
'1
!71204
2,3
11AUTRYVILLE ALL
BC
1 0.60
'1
* This is the maximum application amount allowed for the soil assuming the amount of
nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Page 4 of 9

NARRATIVE OF OPERATION
This WUP has been revised to reflect wettable acres as determined by Starr Maready,
Certified Technical Specialist, WA/WUP, Duplin Co. Cooperative Extension office. A map
and the computations were furnished by Starr Maready.
The 75-lb overseed option has been utilized with the following conditions: (1) no animal waste
may be applied to the bermuda after August 31, (2) an application of 75 Ibs of PAN may be
applied to the small grain in split applications from September 15 - October 30 and in
February - March, and (3) the small grain must be harvested or grazed off by April 7.
Page 5 of 9

PLANS & SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application. Any
discharge of waste which reaches surfacewater is prohibited. Illegal discharges are subject
to assessment of civil pehalties of $10,000 per day by the Division of Water Quality for every
day the discharge continues.
2. The Field Office must have documentation in the design folder that the producer either
owns or has long term access to adequate land to properly dispose of waste. If the producer
does hot own adequate land to properly dispose of waste, he shall provide NRCS with a copy
of a written agreement with a landowner who is within a reasonable proximity, allowing
him/her the use of the land for waste application for the life expectancy of the production
facility. It is the responsibility of the owner of the facility to secure an update of the Waste
Utilization Plan when there is a change in the operation, increase in the number of animals,
method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climate conditions, and level of
management, unless there are regulations that restrict the rate of application for other
nutrients.
4. Animal waste may be applied to land that has a Resource Management System (RMS) or
an Alternative Conservation System (ACS). If an ACS is used the soil loss shall be no greater
than 10 tons per acre per year and appropriate filter strips will be used where runoff leaves
the field. These filter strips will be in addition to "Buffers" required by DEM. (See FOTG
Stantard 393 - Filter Strips and Standard 390 Interim Riparian Forest Buffers).
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland, the
waste may be broadcast provided the application does not occur during a season prone to
flooding. (See "Weather and Climate in North Carolina" in the NRCS Technical Reference -
Environment file for guidance.)
'7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
runoff does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control conditions
conducive to odor or flies and to provide uniformity of application.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops ,on soils with
a high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste shall
not be applied more than 30 days prior to planting of a crop on bare soil.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following:
the outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from anv residential propertv boundary
Page 6 of 9

and from any perennial stream or river (other that an irrigation ditch or canal. Animal waste
other than swine waste from facilities sited on or after October 1, 1995), shall not be applied
closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal Waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landownwer.
14. Waste shall be applied in a manner not to reach other property and public right - of ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted croplands
provided they have been approved as a land application site by a "technical specialist".
Animal waste should not be applied on grassed waterways that discharge directly into water,
courses, except when applied at agronomic rates and the application causes no runoff or drift
from the site.
*16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc.,
shall not be discharged into the animal waste management system.
*17. A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). If needed, special vegetation shall be
provided for these areas and shall be fenced, as necessary, to protect the vegetation.
Vegetation such as trees, shrubs, and other woody species, etc. are limited to areas where
considered appropriate. Lagoon areas should be kept mowed and accessible. Lagoon berms
and structures should be inspected regularly for evidence of erosion, leakage or discharge.
*18. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the possibility
of an illegal discharge, pollution and erosion.
*19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks, and spills. A regular maintenance checklist should be
kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied as a preemergence with no other applications of
animal waste during the crop season.
*21. Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to mark
the maximum storage volume fpr waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soils shall be monitored and alternative crop sites
shall be used when these metals approach excessive levels. pH shall be adjusted for
optimum crop production amd maintained. Soil and waste analysis records shall be kept for
five (5) years. Poultry dry waste application records shall be maintained for three (3) years.
Waste application records for all other waste shall be maintained for five (5) years.
Page 7 of 9

23. Dead animals will be disposed of in a manner that meets North Carolina Department of
Agriculture regulations.
* Liquid Systems
Page 8 of 9

NAME OF FARM: Pigs "R" Us
OWNER / MANAGER AGREEMENT
I (we) understand and will follow and implement the specifications and the operation and
maintenance precedures estalished in the approved animal waste utilization plan for the farm
named above. I (we) know that any expansion to the existing design capacity of the waste
treatment and/or storage system or construction of new facilities will require a new utilization
plan and a new certification to be submitted to DEM before the new animals are stocked.
I (we) understand that I must own or have acces to equipment, primarily irrigation equipment,
to land apply the animal waste described in this waste utilization plan. This equipment must
be available at the appropriate pumping time such that no discharge occurs from the lagoon
in a 25-year 1-day storm event. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates that no runoff occurs.
NAME OF FACILITY WNER: Curtis Brock
SIGNATURE: DATE: lO"�7"9y
NAME OF MANAGER (if different from owner):
please print
SIGNATURE: DATE:
NAME OF TECHNICAL SPECIALIST: George H. Pettus
AFFILIATION: Goldsboro Hog Farms, Inc.
ADDRESS (AGENCY): PO Box 10009
Goldsboro, NC 27532
[phone]
SIGNATURE: DATE: lb 4`uNE.9'1
In
Page 9 of 9

//�T%,/�!I 1%f/UV �' IV✓iV•..ry (/p'/ 'vv �•�F� .a•i7v vl`/11 w�lv-�. `.'v vv.. vliL1 ♦•� - -11i -I Vf/ a �--'-/v
f'Jy`Ilp lVo b 'IL
;a•
4'
v;,Z \
O0
The
IAN
audz k -

0
0
I
1
PPE
9
d� •. rCttT �'

State of North Carolina
Department of Environment,
Health and Natural Resources
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
November 13, 1996
Stanley Curtis Brock
Pigs R Us Inc
4220 N Hwy 111
Albertson NC 28508
SUBJECT: Operator In Charge Designation
Facility: Pigs R Us Inc
Facility ID#: 31-211
Duplin County
Dear Mr. Brock:
Senate Bill 1217, An Act to Implement Recommendations of the Blue Ribbon Study
Commission on Agricultural Waste, enacted by the 1996 North Carolina General Assembly,
requires a certified operator for each animal waste management system that serves 250 or more
swine by January 1, 1997. The owner of each animal waste management system must submit a
designation form to the Technical Assistance and Certification Group which designates an
Operator in Charge and is countersigned by the certified operator. The enclosed form must be
submitted by January 1, 1997 for all facilities in operation as of that date. Failure to designate a
certified operator for your animal waste management system is a violation of 15A NCAC 2H
.0224 and may result in the assessment of a civil penalty.
If you have questions concerning operator training or examinations for certification, please
contact your local North Carolina Cooperative Extension Service agent or our office.
Examinations have been offered on an on -going basis in many counties throughout the state for
the past several months and will continue to be offered through December 31, 1996.
Thank you for your cooperation. If you have any questions concerning this requirement please
call Beth Buffington or Barry Huneycutt of our staff at 919/733-0026.
Sincerely,
d4
A. Preston Howard, Jr., P ctor
Division of Water Quality
Enclosure
cc: Wilmington Regional Office
Water Quality Files
P.O. Box 27687, N%f
�C
Raleigh, North Carolina 27611-7687 An Equal Opportunity/Affirmative Action Employer
Voice 919-715-4100 50% recycled/10% post -consumer paper

i
F,ZGISTRATION FOR^. FOR AINIbLAL FEEDLOT OPERATT_ONS
De_nart^ent of Environment, Health and Natural Resources
Division of Environmental Management
Water Quality Section
_f the animal waste management system for your feedlot operation ,s
designed to serve more than or equal to 100 head of cattle, 75
250 _.n_.:2, 1 , vpp sn--er., c.. 30, !`00 b` rds that arc served ov
a_ieuid waste system, then this form must be f'_'_1ed out and mailed
cv December 31, 1993 pu'rsllant to 15A NCAC 2H.0217(c) in order to be
deemed permitted by DEM. Please print clearly.
=arm Name:
Nail'_..^.c Address:
County:
Owners) Name:
Manacer(s) Name:
lessee Name:
17+0L„v' ?hone No.yiy-658-/Sno
Fasm Location (Be as specific as possible: road names, direction,
^.' 1--post, etc..) : Me- AWq Id , MORTH OF (NTEiKy-cnDN WirH MG47-(532. 10014
.atitude/Lcncitude if :known: amp tb-(2z-(O-iq
Design capacity of animal waste management system (Number and type
_f conf_ned animal (s)) : 3200 uedy MA.RSERy WEAN TO FEEDER)
Average animal population on the farm (Number and type of animal(s)
raised) 3200 Raw
Year Production Began: t4g2 ASCS Tract No.: '7(2o*
Type of Waste' Management System Used: AWA&ytmG iA-000N
Acre_< ."-.vai-able for Land Application of Waste: 7AczacrsaASrAL
Owner(s) Signature(s): DATE: 6-z8-93
ZDATE: 6 ZF-9,J
3i-a�► ,

State of North Carolina
Department of Environment,
Health and Natural Resources 74teA
Division of Environmental Management
James B. Hunt, .SecretaC)
Jonathan B. Howes. Secretary FE
A. Preston Howard, Jr., P.E., Director
October 22, 1993
Curds Brock
4220 N. Hwy. I I I
Albertson NC 28508
Dear Mr. Brock,
This is to inform you that your completed registration form required by the recently
modified nondischarge rule has been received_ by the Division of Environmental Management
(DEW, Water Quality Section.
On December 10, 1992 the Environmental Management Commission adopted a water
quality rule which governs animal waste management systems. The goal of the rule is for animal
operations to be managed such that animal waste is not discharged to surface waters of the state.
The rule allows animal waste systems to be "deemed permitted" if certain minimum criteria are
met (15A NCAC 2H .0217). By submitting this registration you have met one of the criteria for
being deemed permitted.
We would like to remind you that existing feedlots which meet the size thresholds listed
in the rule, and any new or expanded feedlots constructed between February 1, 1993 and
December 31, 1993 must submit a signed certification form to DEM by December 31, 1997.
New or expanded feedlots constructed after December 31, 1993 must obtain signed certification
before animals are stocked on the farm. Certification of an approved animal waste
management plan can be obtained after the Soil and Water Conservation Commission adopts
rules later this year.
We appreciate you providing us with this information. If you have any question about
the new nondischarge rule, please contact David Harding at [phone].
Sincerely,
.�4gSteve Tedder, Chief
- Water Quality Section
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post-cormmer paper