310200_HISTORICAL_20171231

NUH I H UAHULINA
Department of Environmental Qual

�-
WASTEUTILIZATION PLi4N s - s 1
PRODUCER: Wesley Hairr - Hairr 1 Sow Farm
LOCATION: 1188 Veach's Mill Road
TELEPHONE:
910-293-3036
RECEIVED/NCDENR/M
Farrow - Wean
TYPE OPERATION:
Feeder - Finish
JUN U 12015
Wean - Feeder
NUMBER OF ANIMALS:
3500 Farrow - Wean
Water Quality Regional
(Design Capacity)
1000 Feeder - Finish
Operations Section
400 Wean - Feeder
Wilmington Regional Office
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface and/or groundwater. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops in the fields where the waste is
to be applied. This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle. Annual soil tests are strongly encouraged so that all
plant nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and available water holding capacities. Normally waste shall not be applied to land
eroding at greater than 5 tons per acre per year. With special precautions, waste may be
applied to land eroding at up to 10 tons per year. Do not apply waste on saturated soils, when it
is raining, or when the surface is frozen. Either of these conditions may result in runoff to
surface waters which is not allowed under DEM regulations. Wind conditions should also be
considered to avoid drift and downwind odor problems. To maximize the value of nutrients for
crop production and to reduce the potential for pollution, the waste should be applied to a
growing crop or applied to bare ground not more than 30 days prior to planting. Injecting the
waste or disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for analysis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
21-1.0217 adopted by the Environmental Management Commission.
Page 1

WASTE UTILIZATION PLAN'
�t
Amount of Waste Produced Per Year (gallons. ft tons. etc.
3500 6.1 21,350
1,000 animals 1.9(tons)waste/animal/year= 1,900 (tons)waste/year.
400 0.42 168
Amount of Plant Available Nitrogen (PAN) Produced Per Year 23,418
4,900 animals X 2.973469388 lbs. PAN/animal/year = 14,570 lbs. PAN/year. (PAN from N.C.
Guide Std. 633) " Based on 3 years on farm records Tech
See narrative
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner
The following acreage will be needed for waste application based on the crop to be grown and
surface application:
Table 1: ACRES OWNED BY PRODUCER
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
it No, Tvne Per Acre Utilized ADDlication
Hairr
10
AuB
Bermuda (H&G)
244
6.33
1545
March - Sept
Hain
11
NoA
Bermuda (H&G)
284
3.21
912
March - Sept
Hairr
12a
NoA
Bermuda (H&G)
284
2.81
798
March - Sept
Hairr
12b
NoA
Bermuda (H&G)
284
3.94
1119
March - Sept
Hairr
13
NoA
Bermuda (H&G)
284
6.00
1704
March - Sept
Hairr
14
NoA/AU
Bermuda (H&G)
244
6.00
1464
March - Sept
Hairr
15
AuB
Bermuda (H&G)
244
2.97
725
March - Sept
Hairr
16
AuB
Bermuda (H&G)
244
2A7
603
March - Sept
Hair
sub 10
AuB
Bermuda (H&G)
244
2.77
676
1 March - Sept
Hair
sub11,12a,12b
NoA
Bermuda (H&G)
284
3.14
892
March - Sept
Hair
sub 13,14
NoA/Au
Bermuda (H&G)
244
2.90
708
March - Sept
Hair
H
s ub 15,16
AuB
Bermuda (H&G)
244
0.96
234
March - Set
Hair
field 25
AuB
Bermuda H&G)
244
22.60
5514
March - Sept
Hair
field 26
AuB
Bermuda (H&G)
244
26.90
6564
March - Sept
Hairr
field 27
AuB
Crab grass (H&G)
163
6.74
1099
March - Sept
Hairr
field 28
AuB
Crab grass (H&G)
163
22.93
3738
March - Sept
Hairr
ALL
AuB/NoA
Small Grain
501
122.67
6134
Oct - Mar
" OPTIONAL"
Hairr
F27,28
AuB
Millet
203
33.74
6849
Aril - Sept
1 ota l I I LL.O / I 34,4LJ.I I I
'This N is from animal waste only. If nutrients from other sources such as commercial fertilizer are
applied, they must be accounted for. N must be based on realistic yield expectation.
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N
requirements. Beginning in 1996 the Coastal Zone Management Act will require farmers in some
eastern counties of North Caroline to have a nutrient management plan that addresses all nutrients.
This plan only addresses Nitrogen.
Page 2

wASTE_UTILIZATION,PLAN
Table 2: ACRES WITH AGREEMENT OR LONGTERM LEASE
(Agreement with adjacent landowner must be
attached) (Required only if operator does not own
adequate land [see Required Specification 2])
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
See footnote for Table 1.
Totals from above Tables
Acres Lbs. N
Utilized
Table 1 122.67
0 Table 2 year 1 .00
Table 2 year 2 0.00
Total year 1 122.67
Total year 2 F 0.00
Amount of N Produced
Surplus or Deficit year 1
34,4
-
-
34,4
1
-
14,5
(19,8
Surplus or Deficit year 2
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to prevent over
application of nutrient or other elements.
Page 3

1 WASTE UTILIZATI'C1N PLi41N,
e
See attached map showing the fields to be used for the utilization of waste water.
Field Soil Type
No.
Application of Waste by Irrigation
Crop Application Application
Rate (In/Hr) Amount In.)
10,15,16
AuB
Bermuda
0.5
1
Sub10,15,16
AuB
Bermuda
0.5
1
Field 25,26
ALIB
Bermuda
0.5
1
11,12a,12b,13
NoA
Bermuda
0.5
1
Sub 11,12a,12b,
NoA
Bermuda
0.5
1
14
NoA/AuB
Bermuda
0.5
1
Sub 13,14
NoA/AuB
Bermuda
0.5
1
F 27 jAuB
Crab grass
0.5
1
F 28
AuB
Crab grass
0.5
1
THIS TABLE IS NOT NEEDED IF WASTE IS NOT BEING APPLIED BY IRRIGATION, HOWEVER A SIMILAR TABLE WILL
BE NEEDED FOR DRY LITTER OR SLURRY.
"` 2 Lagoons
Your facility is designed for 90 days of temporary storage and the temporary storage must be
removed on the average of once every 3 MONTHS. In no instance should the volume of waste
being stored in your structure exceed Elevation 'see lagoon gauges.
Call the local Natural Resources Conservation Service (formerly Soil Conservation Service) or Soil
and Water Conservation District office after you receive the waste analysis report for assistance in
determining the amount per acre to apply and the proper application rate prior to applying the waste.
Narrative of operation:
This plan is written on 90 days storage volume which should be sufficient to allow for crops drying
and harvest. The acres in this plan are 'wetted' acres. Lbs. N produced is based on 3 years
artiml nmmnina records. took the highest vear which was 1999 with 12,142 lbs. and added 20%
to come up with the amount produced.
On fields 27,28 millet is a option as a summer annual and was reduced for grazing by 25%.
On the crabgrass the N rates and tons per acre were determined by using the abstracts attached.
to WUP. The crabgrass is being treated as common since it is not going to be planted.
Page 4

WASTE UTILIZATIM PLAN
_.
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of waste, he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner of the facility to
secure an update of the Waste Utilization Plan when there is a change in the operation,
increase in the number of animals, method of utilization, or available land.
Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climatic conditions, and level
of management, unless there are regulations that restrict the rate of application for other
nutrients.
Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but less than 10 tons per acre per
year providing grass filter strips are installed where runoff leaves the field. (See FOTG
Standard 393 - Filter Strip).
Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland,
the waste may be broadcast provided the application does not occur during a season
prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order to control odor or flies.
Animal waste shall not be applied to saturated soils, during rainfall events, or when the
Page 5

' WASTE. UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a
high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste
shall not be applied more than 30 days prior to planting of the crop or forages breaking
dormancy.
Any new swine facility sited on or after October 1, 1995 shall comply with the following:
11 The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and from any perennial stream or river (other than an irrigation ditch or canal. Animal
waste other than swine waste from facilities sited on or after October 1, 1995), shall not be
applied closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips).
12 Animal waste shall not be applied closer than 100 feet to wells.
Animal waste shall not be applied closer than 200 feet of dwellings other than those owned
13 by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted wetlands
15 provided they have been approved as a land application site by a "technical specialist'.
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that causes no runoff or drift from the site.
Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
16 not be discharged into the animal waste management system.
Page 6

WASTE<UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced as necessary to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
Animal waste can be used in a rotation that includes vegetables and other crops for direct
20 human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied pre -plant with no further applications animal waste
during the crop season.
Highly visible markers shall be installed to mark the top and bottom elevations of the
21 temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
22 element. Zinc and copper levels in the soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste analysis records shall be kept
for five years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
Page 7

WASTE, UTI LIZATIO WP LAN'_ r
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: Hairr 1 Sow Farm
Owner/ Manager Agreement
I (we) understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. I (we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new facilities will require a new
certification to be submitted to the Division of Environment Management (DEM) before the
new animals are stocked. I (we) also understand that there must be no discharge of
animal waste from this system to surface waters of the state from a storm event less
severe than the 25-year, 24-hour storm. The approved plan will be fled on -site at the farm
office and at the office of the local Soil and Water Conservation District and will be
available for review by DEM upon request.
Name of Facility Owner: Wesley Hairr
(Please print)
Signature: Date: %✓ �.� ' %
Name of Manager (If different from owner)
Signature: Date:
Name of Technical Specialist: (Please print) A. J. Linton
Affiliation: Murphy Family Ventures LLC
Address (Agency): P.O. Box 1139
Wallace, NC 28466
Signature: /y r Date:
.'M

T'6
4 y
4
ti� x
"ttM1 f 1 �
-
nii �5 ,
•
.. ;r,� � ....,;,Ir.: �, _ `r,
�s/=ice'.

7131001O Field Area Measure - Gogg Is Maps
Displaying content from kmlmap.lt.krienas.serve6ai.lt
The content displayed below and overlaid onto this map is provided by a third party, and Google is not responsible for
it. Information you enter below may become available to the third party.
Field Area Measure
Hairr 1 new
Perimeter: 7296.993 ft. Area: 22.93 ac.
hops://maps.googIe.coMmaps?q=http:/MNmap.lt.lTiems.sff%wiai.It/uploads/310714-0145388.IgTi 212

.za, i 11, C,'a S'� l +Y'v - ";rd 1a 1 Sr "'„ G1v.^.. 1 [r. f.fYl' It; P.i ` 1-1Iv✓ I I.O lnt:t a"' A 1
Area of Interest (AOi) _ "I flap Soil Data fxplorcr Download Soils Data Shopping Care (Free)
----_ Printable versmnAdd to shopping earn
_m ra h
lat' Lira 1 vcr.r:
Duplin County, North Carolina (NC061)
Map Unit Map Unit Name
Acres
Percent
symbol
m AOI
of A OI
4u0 Autryville loamy fine sand,
2/.0
100.0%
0 to 6 percent slopes
totals for Area of Interest
27.0
100-0e/o
soil=t.,f_ _F�10--__-��-----
fa !1 `1 I m r+=I.t11TFil ! Seal 14140._.
fS
Warning: Soil Map may not be valid at this scale.
You have zoomed in beyond the scale at which the soil trap for this area is intended to be used. Mapping of soils
done at a particular scale. The soil surveys that comprise your AOI were Trapped at 124,000. The design of ma:
units and the level of detail shown in the resulting soil Trap are dependent on that map scale.
Enlargement of maps beyond the scale of mapping can cause misunderstanding of the detail of mapping and acct
of soil line Placement. The naps do not show tm :he small areas of contrasting soils that could have been shown at
more detailed scale.
FOIA I Accessibility Statement I Privacy Policy I Nan-Discrimnation Statement I Information Quality I USA.gov I 'White House

7/22/2014
Abstract I American Society of Ag rorwny
Search /41hor
The Vol. Issue year I Page
Search Advanced Search
Home n Publicalkms x Forme S Graanglands
Journal Links
Abstract
Zoo( the Journal
Author Information
'Atltl to Uindtti 'piece htr a..du.
Editor/Reviewer Information
This article in FG
doi:10.1x'194iFG-2005-u'S 18-01-RS
Submissions
Nitrogen Fertilization Rate and Application
Editorial Board
Val, 3 No.I
Published: May,2005
'Timing Effects on the Yield of Crabgrass
Email Plans
Journal Statistics
' Corresponding aulhor(s):
Chris D. Teresch ex, John H. Rke , Gordon E Grooverc and William M. Tilsond
Subscription Questions
cteutsch A,adu
O Author Affiliations
Content Questions
View
Browse all Journals
p Abstract
Abstract
r, Full Text
.............................................................................................................................
uFUll Text(PDF)
Crabgrass (Digifaria species) is a summer annual grass that could provide high quality
Formed published
YP Y
��Tablu of Currents
grating for ruminant hoestock in the mid -Atlantic region of the United States- however, little
,E ,
Downloatl
is known about managing crabgrass as a forage in this region. This studywas designed to
.Citation
evaluate the effect of N ferdliver rate and application timing on the geld of crabgrass. Nine N
rates ranging from 0 to 4001b/acre were applied as a single application at seeding or as a
Netts
split application, one-half at seeding and one -halt after the first cutting. Averaged over years,
,,Sign up Ief TOG email ater^s
first harvest yield ranged from 800 to 4000 lb/acre and increased as N rate increased with
maximum dry matter production occurring at 255 to of N per acre. Second harvest Neld was
Permissions
greatest when N was applied as a split application. This effect was most pronounced with
Pxgvest ne.rniz=ionz -
ample rainfall. Total dry matter production, averaged over years, ranged from 3000 to 9000
Ib/acre and increased as N rate increased with maximum dry matter production occurring at
305 Ib of N per acre. Results support current recommendations for summer annual
grasses of applying N at 60 to 80 Ib/acre at seeding followed by N at 40 to 60 Ib/acre after
each harvest and suggest that crabgrass could be managed in a similar manner.
Please view me pdf byusing the Full Text(PDF) link under Mo.'to the left.
Copyright © 2005. © 2005 Plant Management Network.
m Copyright 2014 - Copyright Information, Privacy Statement, and Terms of Use
5585 Guilford Road 1 Madison, WI 53711-5801 1 608-273-8080 1 Fax[phone]
Certification: 608-273-80851 Fax [phone]
hllps/t p .agronomyorg/publications/fg/abstracts/3/1/20050518-01-RS 1/1

7/22/2014 G4661 WarnrSaason Annual Forage Crops I University of Missouri EMension
• Lowest cutting or grazing height
8 inches
Crabgrass
Although commonly considered a weed in
row crops, crabgrass provides high -quality
summer forage and grazing. It is gaining
popularity because it can be used alone,
double -cropped behind winter annual
pastures, or used in combination with
perennial cool -season grasses. Like
peadmillet, crabgrass does not contain
prussic acid.
Productivity of crabgrass is determined by
the availability of moisture. When planted
as a single crop with good growing
conditions and adequate moisture,
crabgrass can yield 4,000 to 8,000 pounds
of dry matter per acre. The improved
cultivar Red River has yielded 8,000 to
10,000 pounds of dry matter per acre under
optimum growing conditions.
Although many stands of crabgrass are
natural ecotypes, improved cultivars can be
established by seeding 3 to 4 pounds of
seed per acre in April. Crabgrass seed can
be broadcast with fertilizer and then lightly
harrowed. Remember that the seed are
small and light and will not broadcast
farther than 25 feet from most fan -type
spreaders. Crabgrass can also be
established using a no -till drill, but because
the seed are small, they should not be
planted deeper than 1/4 inch.
Managed property, this annual grass can
persist as a perennial through natural
reseeding. To ensure natural reseeding,
livestock should be removed at least 3
weeks before the first killing frost to allow
seed to set. The following spring, the
ground should be lightly scratched with a
disk or harrow in late April or early May to
provide adequate soil -seed contact. An
application of 40 pounds of nitrogen per
acre will speed development of a stand.
Animals perform best on crabgrass pasture
if it is grazed rotationally. This allows the
producer to keep the forage in a high -
quality, vegetative growth stage. Ideally, it
should be grazed before it reaches a height
of 8 to 10 inches and not grazed to less
than 3 inches. Beef cattle have gained up
to 2.25 pounds per day on good crabgrass
pasture and have repeatedly gained 0.2
• Suitability for wildlife cover
Poor
Crabgrass
shoots,
including root
system.
Crabgrass at a glance
• Common name
Crabgrass
• Origin
Southern Africa
• Adaptation to Missouri
Statewide
• Growth habit
Sod forming
• Tolerance to drought
Fair
• Tolerance to poor drainage
Poor
• Cultivars
Red River, Common
• Ease of establishment
Easy
• Seeding rates
3 to 4 pounds per acre
• Seeding dates
May 1 to May 31; can be overseeded into
winter annual grasses from late winter to
early spring
• Preferred seeding depth
1/4 to 112 inch
• Days from seeding to first grazing
30 to 45
• Preferred soil pH
5.5 or higher
• Fertilization
40 pounds of N per acre at establishment.
Apply 60 pounds of N after first cutting or
grazing. P and K to soil test.
• Timing of production
http://ebension.rrvssouri.edulp/g4661ikrabgrass 47

�
u
3
goo
W
N
N
V
o0
'Ao
Z
W
3
d^
SL OC. wwnn4.�
reEanaog ,G�oJ itl
vullvmJYuvNfo+anwiS maavaJ ayl
Wl6o+dvYJ'F ryayayJa novuaa0 upon avmudp payynJ,4Ypvs� •
Li66I - VVMI,
. pl+aJ apun 5aT.-L gNaJ apwf)
lney •� .Ca�saM
uoeSsrru
sjomjado uralsd" F nllod 1aJvM V
�- —
7 r-?y,s-2nbpS "oA

PLAN OF ACTION (POA) FOR LAGOON SLUDGE REDUCTION
Facility Number:
Facility Name: V- C I '- w G r ✓wt
County: 0u��
Certified OperatorName:_0P"5`e.V _�Aa y_rOperator#: 9 J `/
Note: A certified Sludge Management Plan may be submitted in lieu of this POA.
Lagoon 1
Lagoon 2
Lagoon 3
Lagoon 4
Lagoon 5
Lagoon 6
n Name/ Identifier
rTotal
ludge Depth(ft)
3S
c. Sludge Depth to be
Removed for Compliance
a • 5
ft
d. Sludge Volume to be
--
Removed (gallons)
e. Sludge PAN
(Ibs/1000 gal)
t)
f. Liquid PAN
See/
(Ibs/1000 gal)
g. PAN of Sludge (Ibs)
(d x e)/1000
n/f)
Compliance Timeframes:
RECEIVED/NCDENR/DWR
If the sludge level is equal to or higher than the stop pump level of the lagoon or if the sludge level
results in an elevated waste analysis, a sludge management plan that meets the rdghir®r Wof SB
Interagency Group Guidance Document 1.26 must be prepared by a technical specialist and submitted to
DWQ within 90 days. Work to reduce the sludge level must begin within anothewillwalayry.RQOr 0liance
with NRCS Standard 359 must be achieved within two years of the original slumeQ.@fs Section
min on egional0ffice
If the sludge level is non -compliant, but below the stop pump level of the lagoon, a POA must be filed
within 90 days and compliance with NRCS Standard 359 must be achieved within two years of the
original sludge survey indicating non-compliance. If future sludge surveys do not show improvement in
sludge levels. DWQ may require the owner to develop a sludge management plan that meets the
requirements of SB Interagency Group Guidance Document 1.26.
SPOA 3-22-2010 Page 1 of 2

w
}
NARRATIVE: Use this section to describe the method(s) that will be used to tower the sludge
depth. If microbe use is planned, specify the product to be used.
The plan for this facility is to agitate and irrigate to reduce the sludge depth. A representative
waste sample will be taken to determine the nitrogen content. This will be done with in house
resources.
I hereby certify that I have reviewed the information listed above and included within the attached
Plan of Action, and to the best of my knowledge and ability, the information is accurate and
correct.
W e- 5 1 e- kR cti % r (
FacilityOwner/Manager (print)
Facility ner Manager (signature)
Phone: `l 1 0- a l I -- 1 `7 S 7
Date: ! (-)' / - H
Return this form to:
Animal Feeding, Operations Unit
NC Division of Water Quality
1636 Mail Service Center
Raleigh, NC 27699-1636
SPOA 3-22-2010 Pana 9 of 7

,N
Murphy Family Ventures
Appendix 1. Lagoon Sludge Survey Form
A. Farm Permit or DWQ Identification Number:
E. Lagoon Identification:
C. Person taking Measurements:
31-200'
H-1 L-2
W Haim
D. Date of Measurement: 9/2/2014
E. Methods/Devices Used for Measurement of:
Start Pump 19
Stop Pump 45.6
Freeboard 29
a. Distance from the lagoon liquid surface to the top of the sludge layer:
b. Distance from the lagoon liquid surface to the bottom (soil) of the lagoon:
c. Thickness of the sludge layer if making a direct measurement with "core sampler":
b-c
PVC Pole
Disk
F. Lagoon Surface Area (using dimensions at inside top of bank): 5 acres
(Draw a sketch of the lagoon on a separate sheet, list dimensions, and calculate surface area.)
G. Estimate number of sampling points:
a. Less than 1.33 acres: Use 8 points
b. If more than 1.33 acres, 1.3 acres x 6 = 7.8 with maximum of 24.
(Using sketch and dimensions, develop a uniform grid that has the same number of intersections as the
estimated number of sampling points needed. Number the intersection points on the lagoon grid so that
data
recorded at each can be easily matched.)
H. Conduct sludge survey and record data on "Sludge Survey Data Sheet" (Appendix 2).
I. At the time of the sludge survey, also measure the distance from the Maximum Liquid Level
to the Present Liquid Level (measure at the lagoon gauge pole): aCj.- jCj s t e -; j 3- , L 3
0.8
J. Determine the distance from the Maximum Liquid Level to the Minimum Liquid Level
(use lagoon management plan or other lagoon records): 1J5.6 - 19 = tr ' rt V- = a •
2.2
K. Calculate the distance from the present liquid surface level to the Minimum Liquid Level
(Item J minus Item I, assuming the present liquid level is below the Maximum Liquid Level):
1.4
L. Record from the Sludge Survey Data Sheet the distance from the present liquid surface level
to the lagoon bottom (average for all the measurement points):
7.9
M. Record from the Sludge Survey Data Sheet the distance from the present liquid surface level
to the top of the sludge layer (average for all the measurement points):
4.3
N. Record from the Sludge Survey Data Sheet the average thickness of the sludge layer:
3.5
O. Calculate the thickness of the existing Liquid Treatment Zone (Item M minus Item K):
2.9
(Note: If Item 0 is less than 4 feet, a sludge remaval and utilization plan may be required by
N.C. DWQ. See your specific permit or contact DWQ for more information.)
P. Proceed to the Sludge Volume Worksheet if you desire to calculate sludge volume for a rectangular -
shaped lagoon with uniform side slopes.
Completed by: W Haim
9/2/2014
Print Name Signature
Dare

w
Murphy Family Ventures
Appendix 2. Sludge Survey Data Sheet'
Sludge Survey Data Sheet
Lagoon Identification: H-1 L-2 Date: 9/2/2014
Completed by: W Hairr
Print Name
Signature
(A)
Grid
Point
No.
(B)
Distance from Liquid Surface
to top of sludge
(C)
Distance from Liquid Surface
to lagoon bottom(soil)
(C)minus (B)
Thickness of Sludge
Laye
Ft. & in.
Ft. tenths
Ft. & in.
Ft. tenths
Ft. & in.
Ft. tenths
1
4.8
7.0
2.2
2
4.5
7.3
2.8
3
5.3
7.7
2.4
4
4.7
8.0
3.3
5
6.9
8.2
1.3
6
5.2
7.4
2.2
7
6.8
7.3
0.5
8
5.5
7.0
1 1.5
9
3.5
7.2
3.7
10
3.0
7.5
4.5
11
5.0
8.2
3.2
12
5.3
7.7
2.4
13
4.8
8.0
3.2
14
4.1
8.0
3.9
15
5.2
8.2
3.0
16
4.0
8.5
1 4.5
17
7.2
8.2
1.0
18
2.0
8.2
6.2
19
2.0
8.3
6.3
20
2.5
7.8
5.3
21
2.5
8.0
5.5
22
3.3
8.4
5.1
23
2.6
8.3
5.7
24
1
2.8
8.1
5.3
Number of points with
readings
X
X
Average
lLof points
4.3
7.9
3.5
At pump
intake
X
X
X
X
'All Grid Points and corresoonding sludge laver thicknesses must be shown on a sketch attached to this
Sludge Survey Data Sheet.
See Appendix 4 for conversion from inches to tenths of a toot.

Murphy Family Ventures
Appendix 3. Sludge Volume Worksheet
Lagoon Identification: H-1 L-2
Completed by: W Hairr
Pnnt Name
1 Average Sludge Layer Thickness (T)
2 Depth of lagoon from top of bank to
bottom soil surface (D)
3 Slope = horizontal/vertical side slope (S)
4 Length at top inside bank (L)
5 Width at top inside bank (W )
6 Length at midpoint of sludge layer
Lm = L - 2 S (D - (T/2))
7 Width at midpoint of sludge layer
Wm = W - 2 S (D - (T/2))
8 Volume of sludge (V)
Vs=LoxWmxT
9 Volume in gallons
VB=Vx7.5gal./f3.
10 Thickness of existing liquid tmt. Zone (Y)
11 Thickness of total treatment zone (Z)
Z=T+Y
12 Length at midpoint of total tmt. Zone
Lz = L-2(S)(D -(Z/2)
13 Width at midpoint of total tmt.zone
Wz = W-2(S)(D - (Z/2)
14 Volume of total treatment zone (Vz)
Vz=LzWzZ
15 Ratio ( R ) of sludge layer volume to total
R=Vs/Vz
Date: 9/2/2014
Signature
3.5
11.1
3
304
340
248.025
284.025
249,494
1,871,203
2.9
6.5
257
293
487,738
0.51

1
t
a
• r4--i-i�i-i�i i �-_

WASTE'U,TILIZATION ,LAN _ .x
PRODUCER: Wesley Hairr - Hairr 1 Sow Farm E:AR
LOCATION: 1188 Veach's Mill Road 7012 2012
TELEPHONE: [phone]
Farrow - Wean--�_
TYPE OPERATION: Feeder - Finish
Wean - Feeder
NUMBER OF ANIMALS: 3500 Farrow - Wean
(Design Capacity) 1000 Feeder - Finish
400 Wean - Feeder
The waste from your animal facility must be land applied at a specked rate to prevent pollution
of surface and/or groundwater. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops in the fields where the waste is
to be applied. This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle. Annual soil tests are strongly encouraged so that all
plant nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and available water holding capacities. Normally waste shall not be applied to land
eroding at greater than 5 tons per acre per year. With special precautions, waste may be
applied to land eroding at up to 10 tons per year. Do not apply waste on saturated soils, when it
is raining, or when the surface is frozen. Either of these conditions may result in runoff to
surface waters which is not allowed under DEM regulations. Wind conditions should also be
considered to avoid drift and downwind odor problems. To maximize the value of nutrients for
crop production and to reduce the potential for pollution, the waste should be applied to a
growing crop or applied to bare ground not more than 30 days prior to planting. Injecting the
waste or disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for analysis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
21-1.0217 adopted by the Environmental Management Commission.
A VVS 31 102zoO
Page 1 Wt92SAW, ptNOEY2-
L, 0

i -z+'e'.3�`r``+a+ai`�,£��09:1-y`ssg3e�.^wy=',��f:
Amount of Waste Produced Per Year (gallons, fttons. etc
3500 6.1 21,350
1,000 animals X 1.9 (tons) waste/animal/year = 1,900 (tons) waste/year.
400 0.42 168
Amount of Plant Available Nitrogen (PAN) Produced Per Year 23,418
4,900 animals X 2.973469388 lbs. PAN/animal/year = 14,570 lbs. PAN/year. (PAN from N.C.
Guide Std. 633) " Based on 3 years on farm records Tech
See narrative
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner
The following acreage will be needed for waste application based on the crop to be grown and
surface application:
Table 1: ACRES OWNED BY PRODUCER
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
ft No_ Tvoe Per Acre Utilized Aoolication
Hairr
10
AuB
Bermuda H&G
239
6.33
1512.87
March - Sept
Hairr
11
NoA
Bermuda H&G
264
3.21
847.44
March - Sept
Hair
12a
NoA
Bermuda H&G
264
2.81
741.84
March - Sept
Hairr
12b
NoA
Bermuda H&G
264
3.94
1040.16
March - Sept
Hair
13
NoA
Bermuda H&G
264
6.00
1584
March - Sept
Hairr
14
NoA/Au
Bermuda H&G
239
6.00
1434
March - Sept
Hairr
15
AuB
Bermuda H&G
239
2.97
709.83
March - Sept
Hairr
16
AuB
Bermuda H&G
239
2.47t
590.33
March - Sept
Hairr
10
AuB
Small Grain
50
6.331
316.5
Oct - Mar
Hair
11
NoA
Small Grain
50
3.21
160.5
Oct - Mar
Hair
12a .
NoA
Small Grain
50
2.81
140.5
Oct - Mar
Hair
12b
NoA
Small Grain
50
3.94
197
Oct - Mar
Hairr
13
NoA
Small Grain
50
6.00
300
Oct - Mar
Hair
14
NoA/Au
Small Grain
50
6.00
300
Oct - Mar
Hair
15
AuB
Small Grain
50
2.97
148.5
Oct - Mar
Hair
16
AuB
Small Grain
50
2.47
123.5
Oct - Mar
"`OPTIONAL'"
'*OPTIONAL'*
Hair
sub 10
AuB
Bermuda H&G
239
2.77
662.03
March - Sept
Hair
subii,12e,12b
NoA
Bermuda H&G
264
3.14
828.96
March - Sept
Hair
sub 13,14
NoA/Au
Bermuda H&G
239
2.90
693.1
March - Sept
Hair
sub 15,16
AuB
Bermuda H&G
239
0.96
229.44
March - Sept
sub 10-16
Small Grain G
50
9.77
488.5
Oct - Mar
Hair
field 25
AuB
Bermuda H&G
239
22.60
5401 A
March - Sept
Hair
field 26
AuB
Bermuda H&G
239
26.90
6429.1
March - Sept
field 25&26
AuB
Small Grain G
50
49.501
2475
Oct - Mar
Hair
field 27
AuB
Fescue
74
6.711
498.76
Au - Jul
Total
66.01
17,706.29
'*OPTIONAL*
"OPTIONAL"
Total 1 33.731 10,146.971
`This N is from animal waste only. If nutrients from other sources such as commercial fertilizer are
applied, they must be accounted for. N must be based on realistic yield expectation.
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N
requirements. Beginning in 1996 the Coastal Zone Management Act will require farmers in some
eastern counties of North Caroline to have a nutrient management plan that addresses all nutrients.
This plan only addresses Nitrogen.
Page 2

Table 2: ACRES WITH AGREEMENT OR LONGTERM LEASE
(Agreement with adjacent landowner must be
attached) (Required only if operator does not own
adequate land [see Required Specification 2])
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
# No. Type Per Acre* Utilized ADDlication
Weaver
F1&F2
NoA/NoB
Corn
118
39.19
4624.42
Feb 15-June
Weaver
F1&F2
NoA/NoB
Wheat
62
39.19
2429.78
Sept - Aril
7054.2
**`YEAR I*
Weaver
F1&F2
NoA/NoB
Wheat
62
39.19
2429.78
Sept -April
Weaver
F1&F2
NoA/NoB
Soybeans
134
39.19
5251.46
Apr - Sept 15
7681.24
"YEAR 2*
**OPTIONAL**
"OPTIONAL`*
Weaver
Sub 17-24
NoA/NoB
Corn
118
27.47
3241.46
Feb 15 - June
Weaver
Sub 17-24
NoA/NoB
Weat
124
27.47
3406.28
Sept - April
Weaver
Sub 17-24
NoA/NoB
Soybeans
134
27.47
3680.98
Apr - Set 15
10328.72
5164.361**2
year rotation"
**OPTIONAL*`
**OPTIONAL*'
* See footnote for Table 1
Total
Totals from above Tables
Acres
Table 1
3:
Table 2 year 1
3,
Table 2 year 2
31
Total year 1
7:
Total year 2
7:
Amount of N Produced
Surplus or Deficit year 1
Surplus or Deficit year 2
39.19
Lbs. N
Utilized
17.
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to prevent
over application of nutrient or other elements.
Page 3

See attached map showing the fields to be used for the utilization of waste water.
Field Soil Type
No.
Application of Waste by Irrigation
Crop Application Application
Rate (In/Hr) Amount (In 1
10,15,16
AuB
Bermuda
0.5
.5-1.0
Sub10,15,16
AuB
Bermuda
0.5
.5-1.0
Field 25,26
AuB
Bermuda
0.5
.5-1.0
11,12a,12b,13
NoA
Bermuda
0.5
.5-1.0
Sub 11,12a,12b,
NoA
Bermuda
0.5
.5-1.0
14
NoA/AuB
Bermuda
0.5
.5-1.0
Sub 13,14
NoA/AuB
Bermuda
0.5
.5-1.0
F1&F2
NoA/NoB
Row Crops
0.5
.5-1.0
sub 17-23
NoA/NoB
Row Crops
0.5
.5-1.0
F 27
Au6
Fescue
0.5
.5-1.0
THIS TABLE IS NOT NEEDED IF WASTE IS NOT BEING APPLIED BY IRRIGATION, HOWEVER A SIMILAR TABLE WILL
BE NEEDED FOR DRY LITTER OR SLURRY.
" 2 Lagoons
Your facility is designed for 90 days of temporary storage and the temporary storage must be
removed on the average of once every 3 MONTHS. In no instance should the volume of waste
being stored in your structure exceed Elevation 'see lagoon gauges.
Call the local Natural Resources Conservation Service (formerly Soil Conservation Service) or Soil
and Water Conservation District office after you receive the waste analysis report for assistance in
determining the amount per acre to apply and the proper application rate prior to applying the waste.
Narrative of operation:
This plan is written on 90 days storage volume which should be sufficient to allow for crops drying
and harvest. The acres in this plan are 'wetted' acres. Lbs. N produced is based on 3 years
actual pumping records, took the highest year which was 1999 with 12,142 lbs. and added 20%
to come up with the amount produced. The leased land in Table 2 is based on a com/wheat/haan
is not
Page 4

.,,+u -^ ,� ryN -�r....cw,�,� m_.. �-t��`'iT•. `x'"�':w� Y�«ir`�. �
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of waste, he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner of the facility to
secure an update of the Waste Utilization Plan when there is a change in the operation,
increase in the number of animals, method of utilization, or available land.
Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climatic conditions, and level
of management, unless there are regulations that restrict the rate of application for other
nutrients.
Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but less than 10 tons per acre per
year providing grass filter strips are installed where runoff leaves the field. (See FOTG
Standard 393 - Filter Strip).
Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland,
the waste may be broadcast provided the application does not occur during a season
prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order to control odor or flies.
Animal waste shall not be applied to saturated soils, during rainfall events, or when the
Page 5

REQUIRED SPECIFICATIONS
(continued)
Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a
high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste
shall not be applied more than 30 days prior to planting of the crop or forages breaking
dormancy.
Any new swine facility sited on or after October 1, 1995 shall comply with the following:
11 The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and from any perennial stream or river (other than an irrigation ditch or canal. Animal
waste other than swine waste from facilities sited on or after October 1, 1995), shall not be
applied closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips).
12 Animal waste shall not be applied closer than 100 feet to wells.
Animal waste shall not be applied closer than 200 feet of dwellings other than those owned
13 by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted wetlands
15 provided they have been approved as a land application site by a 'technical specialist'.
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that causes no runoff or drift from the site.
Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
16 not be discharged into the animal waste management system.
Page 6

F
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced as necessary to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
Animal waste can be used in a rotation that includes vegetables and other crops for direct
20 human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied pre -plant with no further applications animal waste
during the crop season.
Highly visible markers shall be installed to mark the top and bottom elevations of the
21 temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
22 element. Zinc and copper levels in the soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste analysis records shall be kept
for five years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
Page 7

RUN
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: Hairr 1 Sow Farm
Owner/ Manager Agreement
I (we) understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. I (we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new facilities will require a new
certification to be submitted to the Division of Environment Management (DEM) before the
new animals are stocked. I (we) also understand that there must be no discharge of
animal waste from this system to surface waters of the state from a storm event less
severe than the 25-year, 24-hour storm. The approved plan will be filed on -site at the farm
office and at the office of the local Soil and Water Conservation District and will be
available for review by DEM upon request.
Name of Facility Owner: Wesley Hairr
(Please print)
c
Signature: Date: 3 — o2 -
Name of Manager (If different from owner):
Signature:
Date:
Name of Technical Specialist: (Please print) A. J. Linton
Affiliation: Murphy Family Ventures LLC
Address (Agency): P.O. Box 1139
Wallace, NC 28466
Signature: Date: 3';t oZ-
Page 8

1
r
-i
Y
Crusader Farm LLC
Hairr I Sow Farm
1188 Veach's Mill Rd
Warsaw, NC 28398
Dear Crusader Farm LLC:
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Coleco H. Sullins, Director
Division of Water Quality
July 1, 2007 RECEIVED
JUN Z 6 Z007
BY:
Subject: Certificate of Coverage NO. AWS310200
Hairr I Sow Farm
Animal Waste Management System
Duplin County
In accordance with your application received on 30-Jan-07, we are hereby forwarding to you this
Certificate of Coverage (COC) issued to Crusader Farm LLC, authorizing the operation of the subject
animal waste management system in accordance with General Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for the Hairr I Sow Farm, located in Duplin County, with an animal capacity of no
greater than the following swine annual averages:
Wean to Finish: 0 Feeder to Finish: 1000 Boar/Stud: 0
Wean to Feeder: 400 Farrow to Wean: 3500 Gilts: 0
Farrow to Finish: 0 Farrow to Feeder: 0
If this is a Farrow to Wean or Farrow to Feeder operation, there may also be one boar for each 15 sows.
Where boars are unneccessary, they may be replaced by an equivalent number of sows. Any of the sows
may be replaced by gilts at a rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009 and replaces the NPDES
COC issued to this facility with an expiration date of July 1, 2007. You are required to continue
conducting annual surveys of sludge accumulation in all lagoons at your facility; the one-year extension
in Condition III.19 does not apply.
Pursuant to this COC, you are authorized and required to operate the system in conformity with the
conditions and limitations as specified in the General Permit, the facility's CAWMP, and this COC. An
adequate system for collecting and maintaining the required monitoring data and operational information
must be established for this facility. Any increase in waste production greater than the certified design
capacity or increase in number of animals authorized by this COC (as provided above) will require a
modification to the CAWMP and this COC and must be completed prior to actual increase in either
wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Enclosed for your convenience is
a package containing the new and revised forms used for record keeping and reporting. Please pav
careful attention to the record keeping and monitoring conditions in this permit.
Aquifer Protection Section 1636 Mail service Center
Internet: www.ncwatemualitv.om Location: 2728 Capital Boulevard
An Equal Opportunity/Affirmative Action Employer- 50%Recycled/10%Post Consumer Paper
!)Carolina
Naturally
Raleigh, NC 27699-1636 Telephone: [phone]
Raleigh, NC 27604 Fax 1: [phone]
Fax 2: [phone]
Customer Service: [phone]

If your Waste Utilization Plan has been developed based on site -specific information, careful evaluation
of future samples -is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upun abandonmcnt or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are mei prim iv restoc'.ing,
of the facility. 4 '
Per 15A NCAC 02T .0111(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100-foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Per 15A NCAC 02T .1306, any containment basin, such as a lagoon or waste storage structure, shall
continue to be subject to the conditions and requirementsof the facility's permit until closed to NRCS
standards and the permit is rescinded by the Division.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Wilmington Regional Office. The Regional Office
Aquifer Protection staff may be reached at 910-395-3900. If you need additional information concerning
this COC or the General Permit, please contact the Animal Feeding Operations Unit staff at (919) 733-
3221.
Sincerely,
for Coleen H. Sullins
Enclosures (General Permit AWG100000, Record Keeping and Reporting Package)
cc: (Certificate of Coverage only for all cc's)
Duplin County Health Department
Duplin County Soil and Water Conservation District
Wilmington Regional Office, Aquifer Protection Section
AFO Unit Central Files
Permit File AWS310200

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Namml Resources
September 8, 2004
CERTIFIED MAIL 70021000 0005 2389 8676
RETURN RECEIPT REQUESTED
Hairr I Sow Farm
1188 Veach's Mill Road
Warsaw, NC 28398
Subject: Notice of Violation
Hairr I Sow Farm
Facility Number: 31-200
Duplin County
Dear Sir or Madam:
Alan W. Klimek, P.E. Director
Division of Water Quality
This is to notify you of violations to the NPDES General Permit NCA200000 issued on April 9,
2003 under Certificate of Coverage NCA231200.
I
On August 20, k04, Mr. John Farnell and Mr. Samuel Watson from the Wilmington Regional
Office of the Division of Water Quality inspected the farm because of waste ponding observed
by Mr. Chester Cobb during a DWQ fly -over on August 19, 2004. During the inspection, Mr.
Rowland noted several violations.
From the inspection, the following violations were documented:
1) Waste ponding
At time of inspection, the field was saturated and ponded waste was observed in the low
areas of the field.
3
This is in'violation of Condition 11.4 of the NPDES Permit NCA200000, which states,
"Land application rates shall be in accordance with the CAWMP. In no case shall land
application rates exceed the Plant Available Nitrogen rate for the receiving crop. In no
case shall land application rates result in excessive ponding or any runoff during any
given application event."
North Carolina Division of Water Quality 127 Cardinal Drive Extension Phone [phone]
Wilmington Regional Office I Wilmington, NC 28405 FAX (9I0) 350-2004
An Equal Opportunity/Af rma&e Action Employer —50% Recyded/10% Post Consumer Paper
Ivo�`1tCarolina
Jvatura!/y
Customer Service
1-877-623-6748

Hbirr I Sow Farm
Page 2
Sept. 8, 2004
2) Failure to maintain land application equipment.and spray fields.
During the inspection, a leak was observed at an air vent leading to the ponded field.
This is in violation of Condition II. 1 of the NPDES Permit NCA200000, which states,
"The collection, treatment, and storage facilities, and land application equipment and
fields shall be maintained at all times and properly operated."
In response to these violations, this office must receive the following information within
fifteen (15) working days of the receipt of this notice:
a. A written explanation of the violations.
b. A written description of the actions taken or to be taken to bring the violations back
into compliance and to prevent their recurrence.
You may wish to contact your County Soil & Water Conservation District Office, County
Extension office,_ a qualified technical specialist, and/or a professional engineer for any
assistance they may be able to provide.
Be advised that the Division of Water Quality may take further action in these
matters including assessment of civil penalties, injunctive relief, and permit
revocation.
If you,have any questions concerning this matter, please do not hesitate to call Mr. John Famell
at 910-395-3900.ext. 203.
Si. jerely,
Charles F. Stehman, Ph.D., P.G.
Environmental Regional Supervisor I
CFSIKRR!
cc: Billy Houston, Duplin County Soil and Water Conservation District
Kraig Westerb@ke, Murphy -Brown LLC
Patrick Fussell;DSWC•WiRO
Star Jackson, Duplin County Cooperative Extension Service
DWQ Non -Discharge Compliance(Enforcement Unit
DWQ Central.F.iles._„
DWQ 4W ilft n'gt6h%nimah Files'31-200,
S:\WQS\ANIMALS\DUPLIN\2004\31-200 NOVREF

i
■ Complete items 1, 2, and 3. Also complete
Rem 4 if Restricted Delivery is desired.
■ Print your name and address on the reverse
so that we can return the card to you.
IN Attach this card to the back of the mailpiece,
or on the front if space permits.
1. Article Addressed to:
,-5;w
Ai All A
N'L d1739y
A
❑ Agent
❑ Addre
C�a� ef0l
D. 14 delivery addrellisiLRerent from Rem 17 ❑ Yes
If YES, enter delivery address below: ❑ No
3. ce Type
Certified Mail ❑ Ewess Mail
Registered ❑ Return Receipt for Merchandise
❑ Insured Mail ❑ C.O.D.
4. Restricted Delivery? (Extra Fee) ❑ Yes
2. Article Number
frransierrvmservice /aW 7002 1000 0005 2389 8676
Ps Form 3811, February 2004 Domestic Rehm Receipt
102595-02- 1540

enviroch�em
Environmental Chemists, Inc.
6602 Windmill Way • Wilmington, NC 28405
[phone] (Lab) • [phone] (Fax)
710 Bowsertown Road • Manteo, NC 27954
[phone]
ANALYTICAL & CONSULTING
CHEMISTS NCDENR: DWQ CERTIFICATE #94. DLS CERTIFICATE #37729
Customer:
NCDENR-DWQ
127 N. Cardinal Drive Ext.
Wilmington, NC 28405
Attn: John Farnell
Date Sampled: 08/20/04
Sampled By: John Farrell
Ctrram-
SEP 13 2004
BY:
REPORT OF ANALYSIS
Date of Report: September 3, 2004
Purchase Order #:
Report Number:
Report To: John
4-5497
SEP 1 3 2004
PARAMETER
Sample ID: 31-200 Field
Date
Analyzed
Lab ID: # 11696
Nitrate + Nitrite Nitrogen, NO3+NO2-N mg/L
0.28
08/24/04
Ammonia, NH3-N mg/L
91
08/25/04
Total Phosphorus, P mg/L
26.1
08/27/04
Total Kjeldahl Nitrogen, TKN mg/L
188
08/25/04
Fecal Coliform, colonies/100 mL
1,476,191
08/20/04
Comments:
Reviewec

ENVHtONMENTAL CHEMISTS, INC
NCDENR: DWQ Certiacate $094, DLS Certificate 437729
Sample Collection and Chain of Custody,
,, E nJ 1Z,
6602 Windmill Way
Wilmington, NC 28405
Phone: [phone]
Fax: [phone]
i?mail: rcheLptl (diaol.com
RL+nnrt Nn•
Samnle Tvne!.. T = Tnflnant F. = Ff41.. „. cv —1i/., nr
Sample
Identification
S
Collection
er•w
V -
Val U
x
2
UIUU G VLIIW i
PRESERVATION
ANALYSIS REQUESTED
o
g
u
z
d
d
0
za
O
0
DATE
TIME
TEMP
>l-� F�id
►169(�
zoo
►v5'
c
..
Z
G
z
G
G
C
P
G
G
C
P
_
G
G
C
P
G
G
C
P
G
G
C
P
G
G
C
P
G
G
C
P
G
G
C
P
G
G
Transfer I Relinquished By:
Date/Time I Received by:
Date/Time
-� ature when Received: CJ, Accepted: Rejected: Resample Requested: i -
,. BY� Received By:! �', C��sG Date• ' �v Time: �; 20

0
N
W
U
�
�
,o
N■
a
0
3
d
�
v
�
o
s
1
o
�
v
�
�
a
"
3
v
3�-
d1
s
—a
ej
6
U
o
AJ
�
3
�
ro

Michael F. Easley, Governor
William G. Ross Jr., Secretary
rNorth Carolina Departrnent of Environment and Natural Resources
1
� Alan W. Klimek, P.E. Director
September 8, 2004
CERTIFIED MAIL 7002 1000 0005 2389 8676
RETURN RECEIPT REQUESTED
Hairr I Sow Farm
1188 Veach's Mill Road
Warsaw, NC 28398
Subject: Notice of Violation
Hairr I Sow Farm
Facility Number: 31-200
Duplin County
Dear Sir or Madam:
Division of Water Quality
This is to notify you of violations to the NPDES General Permit NCA200000 issued on April 9,
2003 under Certificate of Coverage NCA231200.
On August 20, �004, Mr. John Famell and Mr. Samuel Watson from the Wilmington Regional
Office of the Division of Water Quality inspected the farm because of waste ponding observed
by Mr. Chester Cobb during a DWQ fly -over on August 19, 2004. During the inspection, Mr.
Rowland noted several violations.
From the inspection, the following violations were documented:
1) Waste ponding
At time of inspection, the field was saturated and ponded waste was observed in the low
areas of the field.
Li
This is in violation of Condition II. 4 of the NPDES Permit NCA200000, which states,
"Land application rates shall be in accordance with the CAWMP. In no case shall land
application rates exceed the Plant Available Nitrogen rate for the receiving crop. In no
case shall land application rates result in excessive ponding or any runoff during any
given application event."
North Carolina Division of Water Quality 127 Cardinal Drive Extension Phone [phone]
Wilmington Regional Office Wilmington, NC 28405 FAX [phone]
An Equal OppoNmity/Affirmative Action Employer— 50% Regded/10% Post Consumer Paper
NO"rthCarolina
�atura!!y
Customer Service
I-877-623-6748

Hairr I Sow Farrn
Page 2
Sept. 8, 2004
2) Failure to maintain land application equipment and spray fields.
During the inspection, a leak was observed at an air vent leading to the ponded field.
This is in violation of Condition II. 1 of the NPDES Permit NCA200000, which states,
"The collection, treatment, and storage facilities, and land application equipment and
fields shall be maintained at all times and properly operated."
In response to these violations, this office must receive the following information within
fifteen (15) working days of the receipt of this notice:
a. A written explanation of the violations.
b. A written description of the actions taken or to be taken to bring the violations back
into compliance and to prevent their recurrence.
You may wish to contact your County Soil & Water Conservation District Office, County
Extension office, a qualified technical specialist, and/or a professional engineer for any
assistance they may be able to provide.
Be advised th6t the Division of Water Quality may take further action in these
matters including assessment of civil penalties, injunctive relief, and permit
revocation.
If you have any questions concerning this matter, please do not hesitate to call Mr. John Farrell
at 910-395-3900 ext. 203.
Sirerely,
n zo..6
7 TZ�
Charles F. Stehman, Ph.D., P.G.
Environmental Regional Supervisor I
CFS/KRR/
CC.' Billy Houston, puplin County Soil and Water Conservation District
Kraig Westerbeke, Murphy -Brain LLC
Patrick Fussell;;DSWC-WiRO
Star Jackson, Duplin County Cooperative Extension Service
DWQ Non -Discharge Compliance/Enforcement Unit
DWQ Central Files
DWQ Wilmington Animal Files 31-200
S:\WQSWNIMALs\DUPLIN\2004\31-200 NOVREF

08l20/2004 11:49 9102933036 HAIRP. SOW PAGE 93
Type of Visit O Compliance Inspection (Jppsration Review O Lagoon Evaluation
Reason for Visit O Routine O Complaint O Follow up O Emergency Notification d Omer.
p Dented Access '
Fality Number JU Date
ciof Visit: J� rung 2 v U
10
Not nil O $elow TMreshold
Erfermitted (l Cer tifadd p Conditionally Certified O Registered Date Last Operated or Above Tyrachotd:.»_.._._.._._...
Farm Name: »_!�A(L __t'�._Fa!?..__._.___._.. County:. �JPe�rl_ ____...._..a ..:.
Owner Name:
Alatiing Address:
Fatality Contact
Title:
Onsite Represrntative:. �t 2• — i3s'1 l . _ ._._..._ _ _ _.
Certified
L )MtIOn of Farm:
Phone No:
_.._._. .- Phone No
Integrator. IvI tIl i?H
Operator Certification Number.
W
❑ Swine 0 poultry p Cattle 0 Horse Latitude �e C�` �.: Lossitude =e
_-
i'. Is aiiy deseaiaige observed fiom any part of the operation?
�'-- ❑ Yes ❑ No
Discharge originated at ❑ Lagoon 0 Sptay Field ❑ Other
a- If discharge is observed, was the conveyance man-made? . .i❑ Yes ❑ $70
b. If discharge is observed• did it reach Water of the State? (If yes, notify DWQ) ❑Yes ❑ No
` c. If discharge is observed,.what is the estimated flow -in gal/min?
:.
d...Does discharge bypass a lagoon 'systew? (If yes, notify DWQ) 0 Yes ❑ No
2. Is there evidence of past discharge from any pan of the operation? _. _ -
❑ Yes
3. Were there anyadverse Impacts or potential adverse impacts to the Waters of the State o her than from a discharge? (] Yes
waste
S. Is storiige• tapaeity fSrEboard glus Sturm storage) less than adequate? ❑ Spillway ... ....D Yes
Suycttue 1 Stittetum 2 .. Structure 3 Structure s "Snvctuie- .. _. .. Stricture d
t Identifier: :2
_. ....._
Fr«board (inches): 3-7
r1✓!z ---�--
Contianed t

eB.;20/20(14 11:49 9102933036 HAIRR SOW PAGE 02
acuity T;umberl 3 1+ Z o u Date of inspection 8
5. Are there any immediate threats to the integrity of any of the structures observed? (ie/ trees, severe erosion. [I Yes Q'Na
seepage, etc.)
6. Are there structures on,aite which are not properly addressed and/or managed through a wasto management or 0 Yes No
closure plan?
(If ant of questions 4.6 was answered yes, =0 the actuation posts an
immediate public health or euvirotsmental threat, notify DWQ)
7. Do any of the struchno need maintenancefimprovement? dyes ONO
B. Does any part of the waste management system other than waste structures require maintenant e/improvement? Q Yes CINO
9. Do any stuctures lack adequate, gauged markers with required maximum and minimum liquid level Q Yes []'No
elevation markings?
Waste Application
10. Are there any buffers that need maintenaucelimprovement? ❑ Yes []'No
11. Is th evidence of over application? If yes, check the appropriate box below. l� Yes ❑ No
=Excessive Ponder ❑ PAN Q Hydraulic Overload ❑ Frozen Ground ❑ Copper ind/or Zinc
12. crop VAX Pitn.h,nn (!> 4 14) �G i C'ii'%)
13. Do the receiving crops differ with those designated in the Certified Animal Waste Managen"' t Plan (CAWMP)? ❑ Yes ❑ No
14. a) Does the facility leak adequate acreage for land application? Q Yes Q No
b) Does the facility need a wettable am determination? ❑Yes Q No
c) This facility is pended for a wettable acre determination? Q Yes ONO
15. Does the receiving crV need improvement? 0 Yes Q No
16, Is there a lack of adequate waste application equipment?
Q Yes ❑ No
0dorhog
17. Does the discharge pipe from the confinement building to the storage pond or lagoon fail to discharge agar below
liquid level of lagoon Or storage pond with no agitation? ❑Yes ❑ No
18. Are there any dead aniaWs not disposed of properly within 24 hoots? ❑ Yes 0 No
19. Is there any ovidettee of wind drift during land apphe lbon? (i.e. residue on neighboring vegetation, asphalt, ❑ Yes ❑ No
roads, building structe e, and/or public property)
20. At the time of the inspection did the facility pose in odor or air quality concern? If yes, contact a regional ❑ Yes Q No
Air Quality representa*ve immediately.
1<w«✓w
Corrtirrwtt

RE-GEIVED/DENR/OWQ
AQUIFER PROTECTION SEC.
04 SEP 24 AM 10* 51

oG)LGGGYJU4 1L:47 7LuzC] 40jb HH1KK SUW
•1
PAGE 71
" Fatality Number: 3 t , — 20 0 Date of Inspection 2
Reoulred rats
21. Fail to have Cerdfi¢ of Coverage & General Permit or other Permit readdy available?
❑ Yes
d No
22. Does the facility fail i<o have all components of the Certified Animal Waste Management Plan readily available?
Oe/ WUP, checklists f design, maps, etc.) -'
0 Yes
Q No
23. Does record keepinglh�teed improvement? If yes, check the appropriate box below.
0 Yes
❑ No
❑ Waste Applicazb m 13 Freeboard ❑ Waste Analysis ❑ Soil Sampling
24. Is facility not in coz chance with any applicable setback criteria in effect at the time of desgn?
❑ Yes
d No
25. Did the facility fair have a actively certified operator in charge?
Q Yes
d No
26. Fail to notify' rogio DWQ of emergency situations as requited by General Permit?
Oet discharge, frec*- d problems, over application)
❑ Yes
No
27. Did Reviewernaspe4tor fail to discuss teviewfmspection with cn-site representative?
❑ Yes
O No
28. Does facility requmeie follow-up visit by same agency?
❑ Yes
No
M Were any additional problems noted which cause noncompliance of the Certified AWMP?
Q Yes
13 No
NPDRS Porrdtted Fadb
30. Is the facility covetey under a NPDFS Permit? (If no, skip questions 31-35)
❑ Yes
No
31. If selected, did the fbeili?y fail to install and maintain rainbreakers on irrigation equipment?
❑Yes
[ No
32. Did the facility fail to install and maintain a rain gauge?
❑ Yes
13 No
33. Did the faci7lty fail It conduct an annual sludge survey?
❑ Yes
( No
34. Did the facility fail to calibrate waste application equipmem7
❑ Yes
Cj No
35. Does record keeping' for NPDBS required forms need improvement? If yes, check the Appropriate box below_
❑ Yes
b No
❑ Stocking Form p Crop Yield Form o Rainfall 13 Inspection After I" Rain
❑ 120 Minute Inspections ❑ Annual Certification Form
0 No violations ar iWtiareies on [soled daring this visit. You wM rotxive no further corresoondenee about this vldt
12112103

ANIMAL FACT ITI
2o,/
ANNUAL CERTIFICATION FORM H -1
U
Certificate of Coverage or Permit Number h C A a 3 J a 6 Q County ie%Year 200,3
Facility Name (as shown on Certificate of Coverage or Permit) f cL; r r -1 Sg cd Farm
Operator in Charge for this Facility. WeSIC.11 f CL I r r Certification #-LIT5 7
Land a plication of animal waste as allowed by the above permit occurred during the past calendar year
YES NO. If NO, skip Part I and Part II and proceed to the certification. Also, if an waste
was generated but not land applied, please attach an explanation on how the animal waste was handled.
Part I : Facility Information•
1. Total number of application Fields 0 or Pulls ease check the appropriate box) in the Certified Animal
Waste Management Plan (CAWMP): a.% Total Useable Acres approved in the CAWMP
I as. 4 3
2. Total number of Fields ❑ or Pulls &Tease check the appropriate box) on which land application
occurred during the year: _ a (. Total Acres on which waste was applied ) as 40
3. Total pounds of Plant Available Nitrogen (PAN) applied during the year for all application sites:
. I11'7.1O 2-7
4. Total pounds of Plant Available Nitrogen (PAN) allowed to be land applied annually by the CAWMP and
the permit: I !� ; 7 11.09
5. Estimated amount of total manure, litter and process wastewater sold or given to other persons and taken
off site during the year /) o n P—/ tons Elor gallons ❑ (please check the appropriate box)
6. Annual average number of animals by type at this facility during the previous year:
7. Largest and smallest number of animals by type at this facility at any one time during the previous year:
Largest ��A Ponula+:.� be •F.wh-A L
Smallest h 1A l�� t u
(These numbers are for informational purposes only since the only permit limit on the number of animals
at the facility. is the annual average numbers)
8 Facility's Integrator if applicable:
Part H: Facility Status:
IF THE ANSWER TO ANY STATEMENT BELOW IS "NO", PLEASE PROVIDE A WRITTEN
DESCRIPTION AS TO WHY THE FACILITY WAS NOT COMPLIANT, THE DATES OF ANY NON
COMPLIANCE, AND EXPLAIN CORRECTIVE ACTION TAKEN OR PROPOSED TO BE TAKEN TO
BRING THIS FACILITY BACK. INTO COMPLIANCE.
I . Only animal waste generated at this facility was applied to the permitted sites during Oyes El No
the past calendar year.
RECEIVED
AFACF 3-14-03 MAR 0 2 2004 i
WATER QUALITY SECTO i
Non•0'ucharoe Getup
4,

a
2.
The facility was operated in such a way that there was no direct runoff of waste from
E3 Yes ❑ No
the facility (including the houses, lagoons/storage ponds and the application sites) during
the past calendar year.
3.
There was no discharge of waste to surface water from this facility during the past
19Yes ❑ No
calendar year.
4.
There was no freeboard violation in any lagoons or storage ponds at this facility during
Ryes ❑ No
the past calendar year.
5.
There was no PAN application to any fields or crops at this facility greater than the
eyes ❑ No
levels specified in this facility's CAWMP during the past calendar year.
6.
All land application equipment was calibrated at least once during the past calendar year.
❑ Yes E rNo
7.
Irrlyat:on G.l%bro, Pion will be done by Apr.l ot•i aao y,
Sludge in all lagoons did not exceed the volume for which the lagoon
❑ ❑ No
accumulation
was designed or reduce the lagoon's minimum treatment volume to less than the volume
nIA
for which the lagoon was designed. Ttiis survey will be done by April o1Y .2004
q
8.
A copy of the Annual Sludge Survey Form for this facility is attached to this Certification.
Ow IJ No
9.
Sl•tdge S"rvey mall a clone by R� ril A'!j dooy.
Annual soils analysis were performed on each 3ield receiving animal waste during the
(les ❑ No
past calendar year.
10.
Soil pH was maintained as specified in the permit during the past calendar Year?
E"Yes ❑ No
11.
All required monitoring and reporting was performed in accordance with the facility's
2 Yes ❑ No
permit during the past calendar year.
12.
All operations and maintenance requirements in the permit were complied with during
R"Yes ❑ No
the past calendar year or, in the case of a deviation, prior authorization was received
from the Division of Water Quality.
13.
Crops as specified in the CAWMP were maintained during the past calendar year on all
& Yes ❑ No
sites receiving animal waste and the crops grown were removed in accordance with
the facility's permit.
14.
All buffer requirements as specified on the permit and the CAWMP for this facility were
L7 Yes ❑ No
maintained during each application of animal waste during the past calendar year.
"I certify under penalty of law that this document and all attachments were prepared under my direction or
supervision in accordance with a system designed to assure that qualified personnel properly gather and
evaluate the information submitted. Based on my inquiry of the person or persons who manage the system, or
those persons directly responsible for gathering the information, the information submitted is, to the -best of
my knowledge and belief, true, accurate, and complete. I am aware that there are significant penalties for
submitting false information, including the possibility of fines and imprisonment for knowing violations."
we
Y
or
different from Permittee)
a-,15-641
Date
Date
AFACF 3-14-03

C
+ ' � phy6-B owiti LLC
April 20. 2004
Murphy -Brown. LLC
Rose Hill Division
Contract Growers
Dear Mr. Hairr,
"1 v
MAY 1 2Qp4
P.O. Box 759
hose Hill, NC 28458
910.289-2111
910-289-6478 Fax
If your farm is currently covered by an NPDES permit, as a requirement of your permit, you should have
completed an annual certification form that summarized the environmental activities on your farm for
2003. If you are not under an NPDES permit, ignore this letter. You will recall that one of the questions
on this annual certification form asked for your annual animal population average. In a series of Brower
meetings that many of you attended, we committed to provide you with your annual average inventories
on or around the anniversary date of your permit. Your annual average inventory, based on the
information in our tracking system for groups closed from 4-24-03 through 4-10-04 is as follows:
Facilitv Name
Facilitv No, Permitted
Actual Average
Wesley C. Hairr
Head
03'1'-0300`5 1000 Gilt
Weekly Avg. Gilt Finisher 1011
Ho.11-r Fo Y nS
Fin.
400 Gilt
Weekly Avg. Gilt Nursery 409
Nur.
3734.5 With
Weekly Avg. Sow with Gilt
Boar
Adjustments3682
Alloc f
a ton
If you did not provide the annual inventory average to DENR in your annual report, you should forward
this correspondence to them by the end of the month. They should be sent to the following address:
NCDENR
Division of Water Quality _
Permitting Unit
Ann. Keith Larick
1617 Mail Service Center
Raleigh, NC 27626-1617
In addition, a copy of this correspondence should be kept with your environmental files.
If there are any questions or concerns regarding either the information contained in this letter, or other
environmental issues, please feel free to call me at [phone].
Sincerely,
Krai,g Westerbeek
Director of Environmental Compliance

Name of Pacility:.
Owner(s) Name: -
Mailing)
FEB 2 7 2002
Wettable Acres Determination Certificad_ on
Facility Number:E% ai53
PhoneNo:Lg►O) _ 303(n
C)Li✓
By signing this form, the facility owner and Technical Specialist acknowledge the completion of the
Wettable Acres Determination. All necessary Wettable Acre Determination Field Data Sheets and
calculations were completed to conduct a Wettable Acre Determination. The facility's Waste
Utilization Plan has been amended as necessary to reflect actual wetted acreage. A copy of all
worksheets, calculations, and other Wettable Acres Detcnrtunation documents, along with the
applicable Waste Utilization Plan and Wettable Acre Detervunation Certification :will be filed with
the local Soil and Water Conservation District. A copy wilt also be kept on site with the Ccr[fied
Animal Waste Management Plan. Any future modifications must be approved by a technical
specialist and filed with the Soil and Water Conservation District prior to implementation. If any
modifications. to the existft_ir gation system or any_ new irtigation equipment was required to, adequately address the waste management needs of this facility, an Irrigation Specialist of Professional Engineer has certified the design and installation below.
Owner
Owner
Technical Specialist Name:
Technical SpecialistSignat
If assisted by an Irrigation Specialist or Professional Engineer please read and sign become:
Animal waste application equipment has been designed or modified to apply waste as necessary to
accommodate the waste management plan and according to NRCS Standards. Animal waste
application equipment has been installed according to NRCS Standards and is ready for use,
Irrigation Specialist/PE
Irrigation Specialist/PE Signature: Date:
Submit this form to:
Attn: Sonya Avant
Non -Discharge Compliance Unit
Division of Water Quality
1617 Mail Service Center
Raleigh, NC 27699-1617
W ADC - 7199

J
W QSlr� 4d. r r
STATIONARY GUN SYSTEM
FIELD DATA WORKSHEET *
STATIONARY SPRINKLER
IRRIGATION SYSTEM
I. Gun make and model number p-b d Yl cL
1
2. Gun nozzle size I o'y [inch], ring orifice, taper bore orifice
3. Lateral spacing _ aqn [feet] by gun spacing along lateral [feet]
4. Operating pressure at the gun _ k o [psi]
S. Gun wetted diameter ')DC [feetJ. measured or determined from gun chart
6. Number of guns operating at one time
7 Total number of guns or gun locations in the system
Exterior guns: full circle part circle
Interior guns:
full circle
Gun locations permanently marked: yes no
8. Supply line Permanent pipe Portable pipe
9. Lateral line size [inch]. If there is more than one size, indicate the size and approximate length of
each. Can be done on the map.
*"10. Lateral line length 1CCG ' [feet]. (Longest lateral)
'•11. Supply line size [inch]. If there is more than one size, indicate the size and approximate length of
each. Can be done on the map.
"12. Supply line length [feet]. Maximum pumping distance.
"13. Pump make and model number
'*14. Pump capacity [gpm)
*15. Engine make and model number
or
"16. Electric motor horsepower and rpm -[hp] [rpm]
Note: It is strongly recommended that you field measure the gun wetted diameter. It should be done on the
longest lateral about half -way clown the lateral.
" Locate each gun or gun location on the map. Indicate whether it is full circle or pan circle. Show the location of
the supply line. Irrigated acres are determined by lateral line, by zone, or by field.
" Optional data, furnish where possible
*" Information furnished by
and/or
Signature of owner or facility representative Signature of technical specialist
® Printed name of owner or facility representative
7 _
Printed name of technical specialist
*"* Only the person or people collecting the data should sign the Field Data Worksheet.
15

(Multiple worksheets may be needed)5�e HARD HOSE TRAVELER
I IRRIGATION SYSTEM
Hard Hose Traveling Gun System
COMPUTATIONAL WORKSHEET
I. Farm number (identification) 31-.p[0o Field number (identification) -Fe 1 d -1
2. Irrigation system designation _ffExisting irrigation system _ New/expanded irrigation system
3. Number of travel lanes `7 # Interior lanes _� # Exterior lanes _ feet] Length of pull(Ll)
# Interior lanes # Exterior lanes _ [feet] Length of pull(L2)
# Interior lanes # Exterior lanes _ [feet) Length of pull(13)
4. Wetted diameter a70'� [feet] from Field Data Worksheet
S. Spacing 040' Hydrant spacing [feet] a5;'4, [as a percentage of wetted diameter]
6. Hydrant layout _ Multiple hydrants — Single hydrant _ Excessively spaced hydrants
7. Read the irrigated area per travel pull for the given wetted diameter from the appropriate table and column
based on pattern, spacing, and travel lane location.
Travel lane length (L, _ Interior or ✓ Exterior' pane/hydrant)
• low (a) Acres start end of pull from Table G-C-bS Column
S b G. (b) Acres middle porpto o �pgll (Ll) 3 �7
`J )Pull lea th k e�et X Wette widtha
,S 3 g 1 � _� [feet]) / 43,560
(c) Acres stop end of pull from Table Column
(oTotal acres for travel lane length (Ll) (Sum: a + b + c)
Travel lane length (L) ✓Interior or _Exterior pane/hydrant)
t (a) Acres start end of pull from Table Column
�1,11 (b) Acres inidd��° rt�iorj-Qf u11 (L2)
O (Pull length .1�' of-C JfT X Wetted width 24 [feet]) / 43,560 5 o
5 d (c) Acres stop end of pull from Table Colman
15_al_�6 Total acres for travel lane length (L2) (Sum: a + b + c)
Travel lane length (L_) Interior or _Exterior (lane/hydrant) _
lot (a) Acres start end of pull from Table Column
y • 717 (b) Acres middle Portion of pull (L3)
[Pull length _[feet) X Wetted width [feet]) / 43,560 �5 �'c'
SO (c) Acres stop end of pull from Table Column
5-S , Total acres for travel lane length (L3) (Sum: a + b + c)
8. Multiply the tabulated irrigated acreage value per travel pull by the number of pulls of each
category in the field. Add all of these, and this is the total irrigated acreage for the field.
(a) Acres per travel lane length (Ll) X # Lanes = Acres
(b) Acres per travel lane length (L2) X # Lanes = Acres
(c) Acres per travel lane length (L3) X # lanes = Acres
Total CAVdW wettable acres for field (Sum: 8a + 8b + 80
Wettable Acre Computational Worksheet Completed by: Date:
—
Signature of technical specialist
15

(Multiple worksheets may be needed) HARD HOSE TRAVELER
IRRIGATION SYSTEM
{71hk Hard Hose Traveling Gun System
COMPUTATIONAL WORKSHEET
I. Farm number (identification) Field number (identification)
2. Irrigation system designation _ Existing irrigation system _ New/expanded irrigation system
3. Number of travel lanes # Interior lanes # Exterior lanes _ feet] Length of pull(LI)
# Interior lanes # Exterior lanes _ [feet] Length of pull(L2)
# Interior lanes # Exterior lanes _ [feet) Length of pull(L3)
4. Wetted diameter _ [feet] from Field Data Worksheet
5. Spacing Hydrant spacing [feet] [as a percentage of wetted diameter]
6. Hydrant layout _ Multiple hydrants — Single hydrant _ Excessively spaced hydrants
7. Read the irrigated area per travel pull for the given wetted diameter from the appropriate table and column
based on pattern, spacing, and travel lane location.
Travel lane length (L, ✓nterior or _ Exterior (lane/hydrant)
Co I (a) Acres start end of pull from Table Column
- U=� (b) Acres middle
L Full len S� o
/�tion of pull (LI)
� ( gth [feet] X Wetted widttn�'-�O [feet]) / 43,560
50 (c) Acres stop end of pull from Table Column
5.� Total acres for travel lane length (LI) (Sum: a + b + c)
{� Travel lane length (L, ✓interior or _Exterior pane/hydrant)
(a) Acres start end of pull from Table Column
(b) Acres middle portion of laabpull (L2) SS `t o
I j 1 (Pull length feet] X Wetted width a40[feet)[ / 43,560
(c) Acres stop end of pull from Table Column
S,$ Total acres for travel lane length (L2) (Sum: a + b + c)
Travel lane length (L_) Interior or _Exterior (lane/hydrant)
61 (a) Acres start end of pull from Table Column _
j� 4.7Z (b) Acres middl rtion of pull (L3)
L° [Pull len 5 [feet] X Wetted widtha'lO [feet)) / 43,560
-5U (c) Acres stop end of pull from Table Column
5- Total acres for travel lane length (L3) (Sum: a + b + c)
8. Multiply the tabulated irrigated acreage value per travel pull by the number of pulls of each
category in the field. Add all of these, and this is the total irrigated acreage for the field.
(a) Acres per travel lane length (1,1) X # Lanes = Acres
(b) Acres per travel lane length (L2) X # Lanes = Acres
(c) Acres per travel lane length (L3) X # Lanes = Acres
Total CAWDIP wettable acres for field (Sum: 8a + 8b + 8c)
Wettable Acre Computational Worksheet Completed by:
Date;
-6 S `7e
Signature of technical specialist
15

(Multiple worksheets may be needed) HARD HOSE TRAVELER
IRRIGATION SYSTEM
I'� Hard Hose Traveling Gun System
COMPUTATIONAL WORKSHEET
1. Farm number (identification) Field number (identification)
2. Irrigation system designation _ Existing irrigation system _ New/expanded irrigation system
3. Number of travel lanes # Interior lanes # Exterior lanes _ feet] Length of pull(LI)
# Interior lanes It Exterior lanes _ [feet] Length of pull(L2)
# Interior lanes # Exterior lanes _ [feet] Length of pull(13)
4. Wetted diameter _ [feet] from Field Data Worksheet
5. Spacing Hydrant spacing [feet] [as a percentage of wetted diameter]
6. Hydrant layout — Multiple hydrants _ Single hydrant _ Excessively spaced hydrants
7. Read the irrigated area per travel pull for the given wetted diameter from the appropriate table and column
based on pattern, spacing, and travel lane location.
Travel lane length (I) ✓ Interior or'_ Exterior' (lane/hydrant)
ID Jl (a) Acres start end of pull from Table Column
y.-1-T (b) Acres middle portion of pull (LI)
(� (Pull length jtn [feet] X Wetted widtha4u [feet][ / 43,560 �S`1 J
_ SQ (c)-Acres stop end of pull from Table Column
S.FS� Total acres for travel lane length (Ll) (Sant: a + b + c)
j� Travel lane length (L) -!:::� Interior or _Exterior (lane/hydrant)
• to i (a) Acres start end of pull from Table Column
O �Z (b) Acres middle portion of pull (L2)
(Pull length-<S45 [Feet] X Wetted width,,).4D[feet][/43,560 �5`70
50(c) Acres stop end of pull from Table Column
Total acres for travel lane length (1,2) (Stun: a + b + c)
-- Travel lane length (L) _ Interior or ✓Exterior (lane/hydrant)
, 50 (a) Acres start end of pull from Table Column
t}-I_ (b) Acres middle wrg]fon of pull [feet] X Wette(L3�oo r Iz0
]Pull lengthd width�� [feet]) / 43,560 S`) J
+ (c) Acres stop end of pull from Table Column
Total acres for travel Late length (1.3) (Stun: a + b + c)
8. Multiply the tabulated irrigated acreage value per travel pull by the number of pulls of each
category in the field. Add all of these, and this is the total irrigated acreage for the field.
(a) Acres per travel lane length (L1) X # Lanes = Acres
(b) Acres per travel lane length (1,2) X # Lanes = Acres
(c) Acres per travel lane length (1,3) X # Lanes = Acres
Total CAWW wettable acres for field (Sum: 8a + 8b + 8c)
Wettable Acre Computational Worksheet Completed by: Date:
Signature of technical specialist
15

(Multiple worksheets may be needed) HARD HOSE TRAVELER
IRRIGATION SYSTEM
Hard Hose Traveling Gun System
COMPUTATIONAL WORKSHEET
1. Farm number (identification) Field number (identification)
2. Irrigation system designation _ Existing irrigation system _ New/expanded Irrigation system
3. Number of travel lanes # Interior lanes # Exterior lanes _ feet] Length of pull(LI)
# Interior lanes # Exterior lanes _ [feet] Length of pull(L2)
# Interior lanes # Exterior lanes _ [feet] Length of pull(L3)
4. Wetted diameter _ [feet] from Field Data Worksheet
S. Spacing Hydrant spacing [feet] [as a percentage of wetted diameter]
6. Hydrant layout — Multiple hydrants _ Single hydrant _ Excessively spaced hydrants
7. Read the irrigated area per travel pull for the given wetted diameter from the appropriate table and column
based on pattern, spacing, and travel lane location.
Travel lane length (L, — Interior or _ Exterior (lane/hydrant)
(a) Acres start end of pull from Table �90 Y Column
5-Lo (b) Acres middle on of pull (Li)
IQ [Pull length [feet] X Wetted width a-,() [feet]) / 43,560
4U (c) Acres stop end of pull from Table Column
iO_;33_ Total acres for travel lane length (LI) (Sum: a + b + c)
Travel lane length (L, _ Interior or ✓Exterior (lane/hydrant)
y' (a) Acres start end of pull from "fable Column
5 J1 e a 4'l (b) Acres middle portion of pull (1,2)
t 1 [Pull length`] [feet] X Wetted width Iq0 [feet]) / 43,5601a
"ea(c) Acres stop end of pull from Table Column
3 a.\ Total acres for travel Lane length (1,2) (Sum: a + b + c)
Travel lane length (L) _ Interior or �enor (lane/hydrant) -
.3'S -r6�;L (a) Acres start end of pull from Table Column
a ail (b) Acres middle portion of pull (1,3)1 io+So By %o
12 [Pull lengthld� [feet] X Wetted width Iqo [feet]) / 43,560
•A-.vik�. (c) Acres stop end of pull from Table Column
G R.1 Total acres for travel lane length (L3) (Sum: a + b + c)
8. Multiply the tabulated irrigated acreage value per travel pull by the number of pulls of each
category in the field. Add all of these, and this is the total irrigated acreage for the field.
(a) Acres per travel lane length (Ll)
(b) Acres per travel lane length (L2)
(c) Acres per travel lane length (1,3)
X # Lanes =
Acres
X # Lanes =
Acres
X # Lanes =
Acres
Total CAWNtP wettable acres for field (Sum: 8a + 8b + 8c)
Wettable Acre Computational Worksheet Completed by:
Date:
Signature of technical specialist
15

Wultlple worksheets may be needed) HARD HOSE TRAVELER
IRRIGATION SYSTEM
{ Hard Hose Traveling Gun System
COMPUTATIONAL WORKSHEET
I. Farm number (identification) Field number (identification)
2. Irrigation system designation _ Existing irrigation system _ New/expanded irrigation system
3. Number of travel lanes # Interior lanes # Exterior lanes _ feet] Length of pull(LI)
# Interior lanes # Exterior lanes _ [feet] Length of pull(L2)
# Interior lanes # Exterior lanes _ [feet] Length of pull(L3)
4. Wetted diameter _ [feet] from Field Data Worksheet
S. Spacing Hydrant spacing [feet] [as a percentage of wetted diameter]
6. Hydrant layout _ Multiple hydrants _ Single hydrant _ Excessively spaced hydrants
7. Read the irrigated area per travel pull for the given wetted diameter from the appropriate table and column
based on pattern, spacing, and travel lane location.
Travel lane length (L-) _ Interior or ✓ Exterior gane/hydrant)
35 —1—t. (a) Acres start end of pull from Table Column
(b) Acres middle portion of pull (LI)
G a o; ,qa,
)full length4�J [feet] X Wetted width7ZI O [feet])/43,560 �7a
ab (c) Acres stop end of pull from Table Column
? G4 Dotal acres for travel lane length (Ll) (Sum: a + b + c)
( Travel lane length (L-) — Interior or ✓ Exterior (lane/hydrant)
(a) Acres start end of pull from Table Column
4. Z l (b) Acres middle po on of pull (L2)
t3 [full length Ifeet] X Wetted width a4S [feet]) / 43,560 ��2
5 1 (c) Acres stop end of pull from Table Column
(o-� Total acres for travel lane length (L2) (Sum: a + b + c)
Travel lane length (L, _ Interior or ✓ Fa tenor (lane/hydrant)
to-.), (a) Acres start end of pull from Table Column
'4 (b) Acres middle on of pull (L3)
(Pull length [feet] X Wetted width 3a4S[feet]) / 43,560
5 1 (c) Acres stop end of pull from Table Column
-Q� Total acres for travel lane length (1.3) (Sum: a + b + c)
8. Multiply the tabulated irrigated acreage value per travel pull by the number of pulls of each
category in the field. Add all of these, and this is the total irrigated acreage for the field.
(a) Acres per travel lane length (LI) X # Lanes = Acres
(b) Acres per travel lane length (1-2) X # Lanes = Acres
(c) Acres per travel lane length (L3) X # Lanes = Acres
Total CAWi1IP wettable acres for field (Sum: 8a + 8b + 8c)
Wettable Acre Computational Worksheet Completed by: Date:
Signature of technical specialist -
15

(Multiple worksheets may be needed) HARD HOSE TRAVELER
IRRIGATION SYSTEM
{' Hard Hose Traveling Gun System
COMPUTATIONAL WORKSHEET
1. Farm number (identification) Field number (identification)
2. Irrigation system designation — Existing irrigation system _ New/expanded irrigation system
3. Number of travel lanes # Interior lanes # Exterior lanes _ feet) Length of pull(Ll)
# Interior lanes # Exterior lanes _ [feet] Length of pull(L2)
# Interior lanes # Exterior lanes _ [feet] Length of pull(L3)
4. Wetted diameter _ [feet] from Field Data Worksheet
S. Spacing Hydrant spacing [feet] (as a percentage of wetted diameter]
6. Hydrant layout — Multiple hydrants _ Single hydrant _ Excessively spaced hydrants
7. Read the irrigated area per travel pull for the given wetted diameter from the appropriate table and column
based on pattern, spacing, and travel lane location.
Travel lane length (L-) _ Interior or ✓ terior gane/hydrant)
(a) Acres start end of pull from Table Column
�? (b) Acres middle portion of pull (Ll)
(Pull len n o+ ro o
IS gth�� (feet] X Wetted widthtz [feet]) / 43,560 O G7Zz�
Z(o_ (c) Acres stop end of pull from Table Column
a9 ,, Total acres for travel lane length (Ll) (Sum: a + b +-c)
Travel lane length (L) _ Interior or _Exterior (lane/hydrant)
Acres start end of pull from Table Column
11_ (b) Acres middle portion of pull (L2)%p t �00
1 (Pull length31I [feet] X Wetted tvidth� [feet]) / 43,560
)� (c) Acres stop end of pull from Table Column
a.4 1 Total acres for travel lane length (1,2) (Sunr: a + b + c)
Travel lane length (L,__ Interior -or _Exterior (lame/hydrant)
(a) Acres start end of pull from 'fable Column _
(b) Acres middle portion of pull (1,3)
(Pull length_ [feet] X Wetted width _ [feet]) / 43,560
(c) Acres stop end of pull from Table Column
Total acres for travel lane length (1.3) (Sum: a + b + c)
8. Multiply the tabulated irrigated acreage value per travel pull by the number of pulls of each
category in the field. Add all of these, and this is the total irrigated acreage for the field.
(a) Acres per travel lane length (Ll) X # Lanes = Acres
(b) Acres per travel lane length (1,2) X # Lanes = Acres
- (c) Acres per travel lane length (1,3) X # Lanes = Acres
Total CAWMP wettable acres for field (Sum: 8a + 8b + 8c)
Wettable Acre Computational Worksheet Completed by:
Date:
q0j,�
Signature of technical specialist
15

PRODUCER: Wesley Hairr - Hairr 1 Sow Farm
LOCATION: 1188 Veach's Mill Rd.
TELEPHONE: [phone]
TYPE OPERATION: Farrow - Wean
Feeder - Finish
Wean - Feeder
NUMBER OF ANIMALS: 3500 Sows
1000 Finishing
400 Nursery
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface and/or groundwater. The plant nutrients in the animal waste should
be used to reduce the amount of commercial fertilizer required for the crops in the fields
where the waste is to be applied. This waste utilization plan uses nitrogen as the
limiting nutrient. Waste should be analyzed before each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be balanced for realistic
yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to
maximize the fertilizer value of the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the needs of the crop to
be grown and the nutrient content of the waste. Do not apply more nitrogen than the
crop can utilize. Soil types are important as they have different infiltration rates,
leaching potentials, cation exchange capacities, and available water holding capacities.
Normally waste shall not be applied to land eroding at greater than 5 tons per acre per
year. With special precautions, waste may be applied to land eroding at up to 10 tons
per acre per year.- Do not apply waste on saturated soils, when it is raining, or when
the surface is frozen. Either of these conditions may result ion runoff to surface -waters
which is not allowed under DEM regulations. Wind conditions should also be
considered to avoid drift and downwind odor problems. To maximize the value of
nutrients for crop production and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied to bare ground not more than 30 days prior to
planting. Injecting the waste or disking will conserve nutrients and reduce odor
problems.
The estimated acres needed to apply the animal waste is based on typical nutrient
content for this type of facility. Acreage requirements should be based on the waste
analysis report from your waste management facility. Attached you will find information
on proper sampling techniques, preparation, and transfer of waste samples to the lab
for analysis.
This waste utilization plan, if carried out, meets the requirements for compliance with
15A NCAC 2H.0217 adopted by the Environmental Management Commission.
Page 1

Amount of Waste Produced Per Year (gallons ft tons etc )
3500 6.1 21350
1000 animals X 1.9 (tons) waste/animal/year = 1,900 (amt.) waste/year.
400 0.42 10
TOTAL 23,418
Amount of Plant Available Nitrogen (PAN) Produced Per Year
4844 animals X 2,973469388 lbs. PAN/animal/year = 14,570 lbs. PAN/year. (PAN from N.C. Tech.
Guide Sid. 633) TOTAL 14,570
Applying the above amount of waste is a big job. You should plan time and have
appropriate equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on the crop to be grown
and surface application:
Table 1: ACRES OWNED BY PRODUCER
Tract _ Field Soil Crop Lbs. N Acres Lbs. N Month of
# No. Type Per Acre Utilized Application
Hairr
10
AuB
Wheat
96
6.33
608
Sept - April
Hairr
11
NoA
Wheat
130
3.21
417
Sept -April
Hairr
12a
NoA
Wheat
130 2.81
365
Sept - April
Hairr
12b
NoA
Wheat
130
3.94
512
Sept - April
Hairr
13
NoA
Wheat
130
6.00
780
Sept - April
Hairr
14
NoA - Au
Wheat
112
6.00
672
Sept - April
Hairr
15
AuB
Wheat
96
2.97
285
Sept - April
Hairr
16
AuB
Wheat
96
2.47
237
Sept - April
Hairr
10
AuB
Soybeans
75
6.33
475
March - July
Hairr
11
NoA
Soybeans
114
3.21
366
March - July
Hairr
12A
NoA
Soybeans
1141
2.81
320
March - July
Hairr
12B
NoA
Soybeans
114
3.94
449
March - July
Hairr
13
NoA
Soybeans
114
6.00
684
March - July
Hairr
14
NoA - Au
Soybeans
95
6.00
570
March - July
Hairr
15
AuB
Soybeans
75
2.97
223
March - July
Hairr
1 16
JAuB JSoybeans
75
2.471
185
March - July
TOTAL 1 33.731 71491
`This N is from animal waste only. If nutrients from other sources such as commercial
fertilizer are applied, they must be accounted for. N must be based on realistic yield
expectation.
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N
requirements. Beginning in 1996 the Coastal Zone Management Act will require farmers in
some eastern counties of North Carolina to have a nutrient management plan that addresses
all nutrients. This plan only addresses Nitrogen.
Page 2

Table 2. ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowner must be attached)
(Required only if operator does not own
adequate land [see Required Specification 21)
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
# No. Type Per Acre Utilized Application
* See footnote for Table 1.
Total
Totals from above Tables
1 39.191 13, 873.26
6,936.63 ** 2 Year Rotation**
Acres
Lbs. N
Utilized
Table 1
3. 33
7,148.91
Table 2
2.51
2,625.50
Table 3
9.1
F86.249
6,936.63
Total
16,711.04
Amount of N Produced
14,570.00
Surplus or Deficit
(2,141.04
NOTE: The Waste Utilization Plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient rich and will
require precautionary measures to prevent over application of nutrient or other
elements.
Page 3

_ WAS7 lt7liwi AlIf?NP. . ....
See attached map showing the fields to be used for the utilization of waste water.
Application of Waste by Irrigation
Field Soil Type Crop Application Application
No. Rate (In/Hr) Amount (In.)
11,12,13
NoA
Row Crops
0.5
.5 - 1.0
1,2,14
NoA - Au
Row Crops
0.5
.5 - 1.0
3,4,5,6,7
AuB
Row Crops
0.5
.5 - 1.0
10,15,16
8,9
LyI3
Row Crops
0.5
.5 - 1.0
-v1 + 1
oA po
ros,jEr a p s
THIS TABLE IS NOT NEEDED IF WASTE IS NOT BEING APPLIED BY IRRIGATION,
HOWEVER A SIMILAR TABLE WILL BE NEEDED FOR DRY LITTER OR SLURRY.
** 2 LAGOONS
Your facility is designed for 90 days of temporary storage and the temporary
storage must be removed on the average of once every 3 Months. In no
instance should the volume of waste being stored in your structure exceed
Elevation *see lagoon Gauges.
Call the local Natural Resources Conservation Service (formerly Soil
Conservation Service) or Soil and Water Conservation District office after you
receive the waste analysis report for assistance in determining the amount per
acre to apply and the proper application rate prior to applying the waste.
-Narrative of operation: _.
Plan written based on 90 days storage volume which should be
sufficient to allow for crops drying and harvest A landirrigates w/
dry hydrants and hard hose travellers Fields 10 - 16 cleared in 1997
This plan is written for "wetted acres" and is based on actual pumping
records We used the last 3 years pumping records took the highest
year which was 1999 with 12,142 Ibs and added 20% to it to come
up with the amount produced. The leased land in Table 2 is based on
a corn/wheat/soybean 2 year rotation. Table 3 reflects a corn/
wheat/soybean rotation or the grower may plant sweet potatoes
in any of these fields The most limiting crop is sweet potatoes
Page 4

REQUIRED SPECIFICATIONS
1 Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land
application. Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or
has and agreement for use of adequate land on which to properly dispose of waste,
he/she shall provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for waste application. It
is the responsibility of the owner of the facility to secure an update of the Waste
Utilization Plan when there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for
realistic crop yields based on soil type, available moisture, historical data, climatic
conditions, and level of management, unless there are regulations that restrict the
rate of application for other nutrients-
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year.
Waste may be applied to land that is eroding at 5 or more tons, but less than 10
tons per acre per year providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 - Filter Strip).
5 Odors can be reduced by injecting the waste or disking after waste application.
Waste should not be applied when there is danger of drift from the irrigation field.
6 When animal waste is to be applied on acres subject to flooding, it will be soil
-- - incorporated on conventionally tilled cropland. When applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not
occur during a season prone to flooding. (See "Weather and Climate in North
Carolina" for guidance.)
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
runoff does not occur offsite or to surface waters and in a method which does not
cause drift from the site during application. No pondfng should occur in order to
control odor or flies.
Animal waste shall not be applied to saturated soils, during rainfall events, or when
the surface is frozen.
Pages

REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the
crop is not covered with waste to a depth that would inhibit growth. The potential
for salt damage from animal waste should also be considered.
10 Waste nutrients shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste nutrient loading rates on these soils
should be held to a minimum and a suitable wither cover crop planted to take up
released nutrients. Waste shall not be applied more than 30 days prior to planting
of the crop or forages breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the
following: The outer perimeter of the land area onto which waste is applied from a
lagoon that is a component of a swine farm shall be at least 50 feet from any
residential property boundary and from any perennial stream or river (other than an
irrigation ditch or canal. Animal waste other than swine waste from facilities sited
on or after October 1, 1995), shall not be applied closer than 25 feet to perennial
waters. (See Standard 393 - Filter Strips).
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
-
owned by the landowner.
14 Waste shall be applied in a manner no to reach other property and public right -of
ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or
wetlands by a discharge or by over -spraying. Animal waste may be applied to prior
converted wetlands provided they have been approved as a land application site by
prior converted wetlands provided they have been approved as a land application site by
a "technical specialist". Animal waste shall not be applied on grassed waterways
that discharge directly into water courses, and on other grassed waterways, waste
shall be applied at agronomic rates in a manner that causes no runoff or drift from
the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc.,
shall not be discharged into the animal waste management system.
17 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
Page 6

WASTE UTILIZATION PLAN AGREEMENT
Name or Farm: Hairr 1 Sow Farm
Owner / Manager Agreement
I (we) understand and will follow and implement the specifications and the operation
and maintenance procedures established in the approved animal waste utilization plan
for the farm named above. I (we) know that any expansion to the existing design
capacity of the waste treatment and storage system or construction of new facilities will
require a new certification to be submitted to the Division of Environment Management
(DEM) before the new animals are stocked. I (we) also understand that there must be
no discharge of animal waste from this system to surface waters of the state from a
storm event less severe than the 25-year, 24-Hour storm. The approved plan will be
filed on -site at the farm office and at the office of the local Soil and Water Conservation
District and will be available for review by DEM upon request.
Name of Facility Owner: Wesley Hairr
(please print)
i
Signature: j Date: 2 — D
Name of Manager (If different from owner):
Signature:
Name of Technical Specialist: (please print): Kraig Westerbeek
Affiliation: Murphy Family Farms —
Address (Agency): P.O. Box 759
Rose Hill, NC 28458
Signature: Date:
Page 8

Tract Field Soil
# No. Type
Table t: ACRES OWNED BY PRODUCER
Crop Lbs. N Acres Lbs. N Month of
Per Acre Utilized Application
Jackson
1
NoA-AuB
Corn
98
6.22
609.56
March - July
Jackson
2
NoA-AuB
Corn
98
5.88
576.24
March - Jul
Jackson
3
AuB
Corn
80
5.88
470.4
March - July
Jackson
4
AuB
Corn
80
5.88
470.4
March - July
Jackson
5
AuB
Corn
80
5.88
470.4
March - July
Jackson
6
AuB
Corn
80
5.88
470.4
March - July
Jackson
7
AuB
Corn
80
5.88
470.4
March - July
Jackson
8
LyB
Corn
120
5.881
705.6
March -July
Jackson
9
LyB
Corn
120
5.13
615.6
March -July
Jackson
1
NoA-AuB
Wheat
125
6.22
777.5
Sept - April
Jackson
2
NoA-AuB
Wheat
125
5.88
735
Sept - April
Jackson
3
AuB
Wheat
108
5.88
635.04
Sept - April
Jackson
4
AuB
Wheat
108
5.88
635.04
Sept - April
Jackson
5
AuB
Wheat
108
5.88
635.04
Sept - April
Jackson
6
AuB
Wheat
108
5.88
635.04
Sept - April
Jackson
7
AuB
Wheat
108
5.881
635.04
Sept - April
Jackson
8 -
LyB
Wheat
120
5.88
705.6
Sept - April
Jackson
9
LyB
Wheat
120
5.13
615.6
Sept - April
Jackson
1
NoA-AuB
Soybeans
95
6-22
590.9
June - Sept
Jackson
2
NoA-AuB
Soybeans
95
5.88
558.6
June - Sept
Jackson
3
AuB
Soybeans
75
5.88
441
June - Sept
Jackson
4
AuB
Soybeans
75
5.88
441
June- Sept
Jackson
5
AuB
Soybeans
75
5.88
441
June- Sept
Jackson
6
AuB
Soybeans
75
5.881
441
June - Sept
Jackson
7
AuB
Soybeans
75
5.881
441
June - Sept
Jackson
8
LyB
Soybeans
135
5.881
793.8
June - Sept
Jackson
9
LyB
Soybeans
135
5.13
692.55
June - Sept
Jackson
1
NoA-AuB
Sweet Pot.
50
6.22
311
30 days preplant
Jackson
2
NoA-AuB
Sweet Pot.
50
5.88
294
30 days preplant
Jackson
3
AuB
Sweet Pot.
50
5.88
294
30 days preplant
Jackson
4
AuB
Sweet Pot.
50
5.88
294
30 days preplant
Jackson
5
AuB
Sweet Pot.
50
5.88
294
30 days preplant
Jackson
6
AuB
Sweet Pot.
50
5.88
294
30 days preplant
Jackson
7
AuB
Sweet Pot.
50
5.881
294
30 days preplan
Jackson
8
LyB
Sweet Pot.
50
5.88
294
30 days preplant
Jackson
9
LyB
Sweet Pot.
50
5.13
256.5
30 days preplant
TOTAL 52.5 2,626
Page 10

2000
2000-2001
1999.2000
1999
1998
1998-1999
Tract
Field
Acres
Soybeans
Wheat
'00-01 Total
Wheat
Corn
99-00 Total
Soybeans
Wheat
98299 Total
Jackson
1
5.00
609
165
774.00
518
551
1,069.00
477
343
820.00
Jackson
2
7.00
800
112
912.00
802
734
1,536.00
832
212
1,044.00
Jackson
3
7.00
636
302
938.00
528
734
1,262.00
689
457
1,146.00
Jackson
4
7.00
669
252
921.00
726
734
1,460.00
636
457
1,093.00
Jackson
1 5
7.00
1 619
123
742.00
557
734
1,291.00
318
490
808.00
Jackson
6
7.00
626
428
1,054.00
551
734
1,285.00
416
490
906.00
Jackson
7
7.00
519
212
731.00
617
734
1,351.00
416
490
906.00
Jackson
8
7.00
693
282
975.00
648
734
1,382.00
265
490
755.00
Jackson
9
7.00
588
588.00
760
760.00
531
531.00
Hairr
10
8.00
421
546
967.00
396
396.00
545
545.00
Hairr
11
4.70
283
283.00
-
236
236.00
Hairr
12
9.20
215 1
580
795.00
79
1
79.00
399
399.00
Hairr
13
7.20
483
450
933.00
119
119.00
257
257.00
Hairr
14
7.20
285
285.00
152
152.00
193
193.00
Hairr
15
3.30
_
Hairr
16
3.30
o,oao.w 92,942.00 9,639.00

Sheet1
IRRIGATION SYSTEM DESIGN PARAMETERS
Landowner/Operator Name: Wesley Hairr - Hairr I Sow Farm
Address: 1188 Veaches Mill Road
Warsaw, NC 28398
Telephone: [phone]
Table 1 - Field Specifications
County: Duplin
Date: 10/22/01
Approximate Maximum
Maximum Maximum Application
Useable Size Application per Irrigation
Pull of Field Rate Cycle
Number (acres) Soil Tvoe Slooe % Cron(s) (In/hr) !inches) Cnmmanfe
1
6.22
NoA-AuB
<5
Row Crops
0.5
.5-1.0
2
5.88
NoA-AuB
<5
Row Crops
0.5
.5-1.0
3
5.88
AuB
<5
Row Crops
0.5
.5-1.0
4
5.88
AuB
<5
Row Crops
0.5
.5-1.0
5
5.88
AuB
<5
Row Crops
0.5
.5-1.0
6
5.88
AuB
<5
Row Crops
0.5
.5-1.0
7
5.88
AuB
<5
Row Crops
0.5
.5-1.0
8
5.88
LyB
<5
Row Crops
0.5
.5-1.0
9
5.13
LyB
<5
Row Crops
0.5
.5-1.0
10
6.33
AuB
<5
Row Crops
0.5
.5-1.0
11
3.21
NoA
<5
Row Crops
0.5
.5-1.0
12 A
2.81
NoA
<5
Row Crops
0.5
.5-1.0
12 B
3.94
NoA
<5
Row Crops
0.5
.5-1.0
13
6.00
NoA
<5
Row Crops
0.5
.5-1.0
14
6.00
NoA-Au
<5
Row Crops
0.5
.5-1.0
15
2.97
AuB
<5
Row Crops
0.5
.5-1.0
16
2.47
AuB
<5
Row Crops
0.5
.5-1.0
86.24

Sheet2
TABLE 2 - Travelling Irrigation Gun Settings
Make, Model and Type of Equipment:
Travel
Application
TRAVEL LANE
Wetted
Nozzle
Operating
Operating
Speed
Rate
Effective Effective
Diameter
Diameter
Pressure
Pressure Arc
Pull No. (f /min)
(in/hr.)
Width(ft.) Lenoth(ft)
(feet)
(Inches)
at riin/nci)
nt roav n
1
1.62
0.45
255
865
270
1.08
60
95
330
2
1.62
0.45
240
865
270
1.08
60
195
330
3
1.62
0.45
240
865
270
1.08
60
95
330
4
1.62
0.45
240
865
270
1,08
60
95
330
5
1.62
0.45
240
865
270
1.08
60
95
330
6
1.62
0.45
240
865
270
1.08
60
95
330
7
1.62
0.45
240
865
270
1.08
60
95
330
8
1.62
0.45
240
865
270
1.08
60
95
330
9
1.95
0.62
220
865
270
1.08
60
95
220
10
1.62
0.45
270
865
270
1.08
60
95
330
11
1.95
0.62
190
567
270
1.08
60
95
220
12 A
1.95
0.62
160
600
270
1.08
60
95
220
128
1.95
0.62
210
690
270
1.08
60
95
220
13
1.62
0.45
245
865
270
1.08
60
95
330
14
1.62
0.45
245
865
270
1.08
60
95
330
15
1.95
0.62
210
462
270
1.08
60
95
220
16
1.95
0.62
210
371
270
1.08
60
95
220
0.00

Sheet7
CALCULATIONS
Sprinkler Type:
Nelson 150
Nozzle Size:
1.08 inches
Sprinkler Pressure:
60 psi
Flowrate(GPM):
182 gpm
Wetted Diameter:
270 feet
Desired Spacing (%):
85 %
Design Spacing(feet):
229.5 'PVC irrigation pipe normally comes in 20' pieces,
so round to the nearest multiple of 20.
Actual Spacing (feet):
240 feet
Actual Spacing (%):
89 %
Application Rate =(96.3xFlowrate)/(3.1415x(.9xradius)squared)
Design App. Rate = 0.38 in/hr
300 degree arc =
0.45 in/hr
220 degree arc =
0.62 in/hr
180 degree arc =
0.76 in/hr
Traveller Speed
Travel speed = 1.605 x Flowrate / Desired application amount x Lane Spacing
Desired app. (in.) = 0.75 inches
300 degree arc = 1.62 ft/min _
220 degree arc = 1.95 ft/min
180 degree arc = 3.25 ft/min
Mainline Velocity
Velocity = .408 x Flowrate / pipe diameter squared feettsec."`
"For buried pipelines, velocity should be below 5 feet per second
Pipe size: inches
Velocity= #DIV/0! ft/sec.
Page 7

Sheett
IRRIGATION SYSTEM DESIGN PARAMETERS
Landowner/Operator Name: Wesley Hairr
Address: 188 Veaches Mill Rd.
Warsaw, NC 28398
Telephone: [phone]
Table 1 - Field Specifications
Approximate
Maximum
Useable Size
Field of Field
County: Duplin
Date: 02/14/2001
Maximum
Maximum Application
Application per Irrigation
Rate Cycle
Comments

Sheet2
TABLE 2 - Travelling Irrigation Gun Settings
Make, Model and Type of Equipment: a' V\.'A.o 9c
Travel Application TRAVEL LANE Wetted Nozzle Operating Operating
Speed Rate Effective Effective Diameter Diameter Pressure Pressure Arc
Hvdrant No. (ft/min) (inthr.) Width(ft.) Lenoth(ft) (feet) (Inches) at Gun(Dsi) at reel(osi) Pattern Comments - Acres ner null
©®�®
:�.
..
Boa
<•

Sheet4
TABLE 4 - Irrigation System Specifications
Traveling
Solid Set
Irrigation Gun
Irrigation
Flow Rate of Sprinkler (g m)
182
Operating Pressure at Pump (psi)
117.6
Design Precipitation Rate (in/hr)
0.31
Hose Length (feet)
1000
XXXXXXXX
Type of Speed Compensation
Mechanical
XXXXXXXX
Pump Type PTO, Engine, Electric
Engine
Pump Power Requirement h)
25.0
TABLE 5 - Thrust Block Specifications
THRUST BLOCK
LOCATION
AREA (sq. ft.)
90 degree bend
2.82
Dead End
2
Tee
1.40
Gate Valve
2
45 degree bend
1.52
Page 1

Sheet5
IRRIGATION SYSTEM DESIGNER
Name:
Kraig Westerbeek
Company:
Murphy Brown LLC
Address:
PO Box 759 Rose Hill, NC
Phone:
[phone]
Required Documentation
The following details of design and materials must accompany all irrigation designs:
1. A scale drawing of the proposed irrigation system which Includes hydrant locations, pipelines, thrust block locations and buffer areas where applicable.
2. Assumptions and computations for determining total dynamic head and horsepower requirements.
3. Computations used to determine all mainline and lateral pipe sizes.
4. Sources and/or calculations used for determining application rates.
5. Computations used to determine the size of thrust blocks and illustrations of all thrust block configurations required in the system
6. Manufacturers specifications for the Irrigation pump, traveler and sprinkler(s).
7. Manufacturers specifications for the Irrigation pipe and/or USDA-NRCS standard for IRRIGATION WATER CONVEYANCE.
8. The Information required by this form are the minimum requirements. It Is the responsibility of the designer to consider all relevant factors at a particular site and
address them as appropriate.
g. Irrigation pipes should not be Installed In lagoon or storage pond embankments without the approval of the designer.
NOTE: A buffer strip of W or wider must be maintained between the limits of the irrigation system and all
perennial streams and surface waters per NC Statutes.

Sheet6
Narrative of Irrigation System Operation
This design is for an addition onto the existing system for this farm. The acreage shown is indicative of a 'new' system desig
criteria.
Grower is farmiliar with the operation of all equipment necessary for this design. 50' property line setback
must be maintained for all irrigation events.

Sheet8
ACREAGE CALCULATIONS
Pull #
Width
Length
Start End
Stop End
Pull Acres
Field Acres
17
234
850
0.49
0.41
5.47
39.19
18
_ _ 198
850
_ 0.49
0.205
4.56
19
220
850
0.49
0.41
5.19
20
220
850
0.49
0.41
5.19
21
227
850
0.49
0.41
5.33
22
165
500
0.49
0.41
2.79
_
23
227
850
0.49
0.41
5.33
24
227
850
0.49
0.41
5.33
39.19
Page 1

Sheet?
CALCULATIONS
Sprinkler Specifications
Sprinkler Type: Nelson 150
Nozzle Size: 1.08 inches
Sprinkler Pressure: 60 psi
Flowrate(GPM): 182 gpm
Wetted Diameter. 300 feet 'based on 90% of manufacturer's table
Lane Spacings
Desired Spacing (°h):
70 %
Design Spacing(feet):
210 feet
Actual Spacing (feet):
220 feet
Actual Spacing (%):
_ 73 %
Application Rate
Application Rate =(96.3xFlowrate)/(3.1415x(.9xradius)squared)
Design App. Rate =
0.31 in/hr
300 degree arc =
0.37 in/hr
220 degree arc =
0.50 in/hr
-180 degree arc =
0.61 in/hr
Traveller Speed
Travel speed = 1.605 x Flowrate / Desired application amount x Lane Spacing
Desired app. (in.) =
0.75 inches
300 degree arc =
1.77 ft/min
220 degree arc =
2.12 ft/min
180 degree arc =
3.54 ft/min
Mainline Velocity
Velocity = .408 x Flowrate / pipe diameter squared feet/sec."
"For buried pipelines, velocity should be below 5 feet per second
Pipe size:
4 inches
Velocity=
4.64 ft/sec.
Page 1

Sheet7
Maximum Mainline Friction Loss
Most distant hydrant: 17
Total distance: 1000 feet
Friction Loss is figured using Hazen/William's Equation
Friction Loss= 1.75 feet/100 feet
Max. Mainline Loss = 17.5 feet or 7.6 psi
plus friction loss in existing 6" line @5psi
Total Dynamic Head
Sprinkler Pressure: 60 psi
Loss through traveller: 35 psi
Elevation head: 2.2 psi
Mainline loss: 12.6 psi - —
Suction head and lift: 2.2 psi
5% fitting loss: 5.6 psi
TOTAL(TDH) = 117.6 psi or 271.7 feet
Horsepower Required
Horsepower = Flowrate x TDH(feet) / 3960 / Pump effeciency
Pump Description: Berkeley B3JQBM
Pump Efficiency: 50 %
Horsepower Required: 25.0 Hp
Thrust Blocking
Thrust Block Area = Thrust / Soil Bearing Strength
Thrust:
2400 feet
Soil Bearing Strength:
1200 feet
End Cap:
2.0 ft2
90 degree elbow:
2.8 ft2
Tee:
1.4 ft2
45 degree elbow:
1.5 ft2
Pipe Pressure Rating Check
Pressure Rating of Pipe to be Used: 200 psi
Max. Pressure on system when running: 117.6 psi
70% of Pressure Rating: 140 psi
If Max. Pressure on system is less than 70% of Pressure Rating, OK
Net Positive Suction Head Check
Page 2

�,i1.A}i{maxi, -�`t'-he +,j r %aj! :,ij�"3 1�(„� ✓) //
HN+.c4h
/Jn l� ,.k. 4(,ls *.1 le'r-r f+kr .„"�{ �/L �I u\ i! r ✓ ti'' i ��
Ar- T V, '
t (Zi 1x`t dd�' yl+T" , .`�. ve)H ire♦ t ri s°r a rY 4'?[I iR �i� yr• �^ ! 7M:?5ry+r�+R'..
w.
i S 'y/ 1 I-i,�[,�.r� t 'rYs at11, F. +.t./ .l // �• y
✓'! n .n 'x f .t ,.r! a.: ^ ..r"M^' I ai x i Jl 3!'." Y , v`: 1- ,CI°R c'Y v
rE �t t i rk f% drs,4 �-..✓ 1 { a,9h A.1i x �'.
V J♦ µr a��it1J; 'Sr �i 45 tl �' � �' l•i%'> .w+.: l 4�j't': tYY�q� jt�fn913 "+�. 1 �" 5!�y';,Y,ny *{fit S}i�r S�„rl,^V
'.. r tr! � �x Fb. t.. ro 7 ^'"" y+".'n, t r '.x Ja"> Fd'. 1,^..� � c+lrr�yi::1�F� I`' 4 „+r5. raj/ wit _1•V2 \ f.t x F�x'F"­'T'
lsri.��}}�.Y w.Ya/+G�` t `Kynb L �i i-" /r tirita'�
4Z,.
��I1i T� 5 l Jq � 51 l✓. '4 �n ti"- r
SW
M1art.Y S 4� k i �i�.tls � H�.'k.,i i�
,yu��''�rnb'�i - l;r
-rY�(+r�7ji,�
ay jr irY
ttS�<X 5r' .0 +Gt}: P � VSrY'ri iro'..'J v fy C• a rr �i: . �r'r �W{,+ittr+. p�.�J, ,y J< f'' c J r t',. 'T
ti n• 5 l � S } !r� °� r .y �r i � � ,f j `� I.4 �— ,�,, /� >t }. . �. 'r ,� [.
' i}k (rA : j+ t f r' p'lI -✓ . yf�'� 4.i. � �i la tit t y �.1.7.5 +,+-. {`rt.'( .O .•Ha�v.�'. �..•i'v ' i J!f'r r �} S
1t. S. ` w` t.�`' Y�•► 4,x /Intl i"rt ,��l71f�$..S fitb�f„r4y}t�..� _
YR Jd n o k"-��
a x - � 4 i � r >< 13 q✓t'O+ r..� J �'"' `M � n sx�fl�
%� yj/ Pel, WyIr x'fi�i'y > � r'rr tk >RiT J t�jy�.'5 ¢�
'✓ � ti �5 r� ° � n �v t ' � °tY. �r� iFn t� yl r Sy ° Rrr��!
yo
�1 Sy JfG.
r, humpy,
urr!
All `as r10 oat A at I"'��kF c}at'
VV rr 11I Air",YfrC''� Gei'ux,r
r
I M"�\i''/�r tt �' n1/ ♦ ,:� ./s" wy .>✓ t• IS I
Ali r- ✓ a r q 41 et t i r r 1 is e AV I ?x lti n y V '(J14ryVr
7p ��..V ar�3tl✓.ot r Jr � sr �I � AI i 'i Ur r f{J x}� r 'ii 't("..Fb�. E
t���V.
- ^ ! t fl/� 5 '�� I J.• / a t F r -4 .P it ^a� l o¢t 5, Ni v5iiy,'','YV'
/ y ! y ri %��, t� � l i §•C4)• .i- , t df>' iTM}'[ t, r a ' ! 'J n a ay i 'a H i
�rt
l�" av ": " s 1 A. ✓F jr 4' * _., �' It,..y. r x atr r r'. r a(� YSMx•h pit, t U T y r \ �• �K
t±, '. ry r�n Y� elsj 1 J'; tr t.y 1p, 1+ '.°�rrrx 2Jr Uia���rl 4yJt 1.
f < 5r 1 r;, ar j. I r-t "rt' a r < ty * at yyxti',*n .:•Jy!3
'i 4A r:r s,i7rct WJt r IJ , I it ✓Y ✓ k r/ytr*-to.f-Aw
t i Jtr tJ
.44
t° t r i' 4 y+ r t✓ �Ti r f n ,x"x' r x
�.l � l r1�'-: ..r't( Is r r I. C y y � 1s'7 '4 r i'j, a Nr^ r v. '-aw'-�.x �5p5r f{,jrr•
K tahr..� � Imo(, !, �•y-1trY it .: I h Ir:•1/ 5 � </a�J 54 {f �!J}a. rt � Y r �tr aS ! ar irt��(�(L�.4�4,SLc+4�/aa p�'
ti 't I r" t,.• ff ✓v' x � fy'f y..'i ty"iaJlla i Y`'ti
r
. ! yC 11 r, 1 CiS`°tS ut, iIt�F ,tray M 1 arl,'SJr��y's�`Y/✓�`�il iSX�
I`Ww�C Yt+�n'�J'�ILLtt Yt.
Pp w D rr I i y " s Y1 �% iab �i5
l..e:1 7 f v�:r! riA ,�rlsfePa .. •s i. :Yw
-1}'�`!,t
rn iyk `6p'ea'irf
I fs ✓'bx v., i'� ��Cl� f `a y.txt Nrb:S
I r! Y.°eh Ay � x y i I a Ya t ,n V/ .� a$Mh44 J yore Jy
�3 xF �b rRli t r •r"`�It .rca f> sr' la.,' +t'1 �+#��ir+�x9 •wyA
!•<• v � r I �,r !:f fi s -Y'x r xt / 1r. .r•C 'ily�/ril.•hr r1 S1
i },� J J �15 •�y;f _ 2: 1 ti'�tJ�,y{4i 6fr )J
ayAeLG.0
\yq jig
\v d yir�,} Ja 5 r I•" ! x' `n liifFl r�'IErNia.{t
Avear tr'
A
f FdSy to i .
sy
All
akF��
vfh�'� • t•.
1
99, .
*t`
c
yJ.n py
t t3
4' . .11
0
51.
y<
0
* y
VA,
t v. YAf.✓� f
��fya51tl� F k -, yil
jl

r v I1 ) •�� Ar "• r ,. S.... '' xL � ��r .'T� � ..r rr 7 �� t r, ' r ' �. , x.
�t3;
.`) .,, 4 5 •. r .l rs L it t �<' ) � 'l ?' �p,tar° � }' .., < f w , T �..y
ra
tk
♦ .':'- x - r. t Y + t ti :-: �r krt •�.t!•r�" �x yi"f' `..
., ,r. y, } s tat I ���' t��•�. `n•)� �� �!) i r 'rJ( ,
,
.
Q r �.
)
i
wl
It
/'�.' ( �/ , x � • V [s r'r� fJY7r} )t , 'f �. �N, t �(' t � �
) / X t" �Lv:G�, a � -r` i X w-� 4t4 rw �tlR ,rrr` ) i� '� 1� 'ry , 'I ''' .,'F. f •'O ' :�
f �, ].i � r t�. �,•r 4 r4 :.gut tr'� )+�� `` L i.'L. , M �� A".3 t
,FS 1,Fy , < . �, 1 li i t� i ) ,{. r` .—� ` 1ex .iol9 •.
j5.T 1 J Wt:i+ f ♦' ?�'�yr1 E ., rY \i`` •,� r�Y�.•i' ) :`
! ) + vrV •r i i,t jr ���,+✓(.R-1` S r .i�� ��' iJ�T. Ir,..y +ti-F-��..,
r
t Sr mQy �. a 1' +� r y 7 i•� x ,. <r'°9 ,,'��A�y..d� '�' v 'Y ` ✓� F 4{L� s�er't' i. r 1 A�'l.{�-
� sterf"Ri!✓1� :. T� 1� ' t .,' J 1 ' .. � ♦ ., , : I, ' I�/�. }J .. '
(i C l 5�r+t 7< ✓`". 4:f 'j !�!�-"T1"♦ 6'1?f'' b'i7�'1 t � �� Y �Yr� I�x �/ '� 1 l��''`y ,\'ti i!i)1? 1� .f �� ��.
t
♦,;�v}•�►•Lj �i�•� + k 4+,! t y��� ',�r drt�;3rt'3'�l i � `�'� 4•. ��� i ...JJ� j«
�'� �/ , i\ w5, 4 „, \ T�i. �t �?�� elf• , < 1, /� / - / f. �-'
"f, �tf ,1/ it � SX \ 1 ♦ f r '� /f({ r<f>A' , /` , f '
OF
p' � �� �� '�,�s l py �Jb �'► �rir.) ` �� -r,,1 t r _ , t i �„+ ,: '�� ,
' '-. I �/ ( V r C yr x : �, t .:l 1. ���of ; / / / /. ) •), A •-) !. Y, •,
r Y y Yyyl-T,�,4{�•I Ix ,, iaf j.! � / IFK I r, ,�.1{ ,' ryj. ., '7< ' f't' i
�'!"ir' r'_�� (f-'riC:i� •'T!iRl{�;�!• �r�.r�3'i��✓�f�. . V. • 7.r a. i. �"Jj.: � • ns✓'. � ! , r ..p. p . �,: i . �. 'I:,-,1.. .: Jr n
.od }ac
Ac'A Oo

Ally,
Agm
I W
NN
All"

•• Sa

State of North Carolina
Department of Environm tTIE tEC- 1VED
and Natural Resources FFR 13 2001
A11101111—�...mN
y M
Michael F. Easley, Governor BY-=---_—.-_.__ NCDENR
William G. Ross Jr., Secretary
Kerr T. Stevens, Director NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
February 5, 2001
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Wesley Hairr
Hairr I Sow Farm
1188 VeachOs Mill Road
Warsaw NC 28398
Subject: Notification for Wettable Acre Determination
Animal Waste Management System
Hairr I Sow Farm
Facility Number 31-200
Duplin County
Dear Wesley Hairr:
A letter dated January 15, 1999 was sent to advise you about concerns associated with Certified Animal
Waste Management Plans and the method by which the irrigated acres within the plans were calculated. Only
the acres that are wetted can be credited in the waste management plan as receiving waste application. Any
acreage within the plan that can not be reached by waste application equipment can not be used as part of your
plan.
An evaluation by Dean Hunkele on 6/22/99 was made to review the actual number of acres at your
facility that receive animal waste during land application. The evaluation of your facility has yielded one of
the following two results as indicated by the box marked with an "X".
Category 1:
❑ The evaluation of your facility could not be completed due to a lack of information. Please
contact your Technical Specialist to assist in providing Dean Hunkele the necessary
information to potentially exempt your facility from undergoing a complete wettable acre
determination. Please submit this information to Dean Hunkele, at 127 Cardinal Drive
Extension, Wilmington, NC 28405-3845, within in 90 days of the receipt of this letter. If you
have any questions please contact Dean Hunkele at [phone]. If within 90 days you
are unable to provide Dean Hunkele with the information you are automatically
required to complete a Wettable Acre Determination as described by Category 2
below, within 180 days of receipt of this letter.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

Notification for Wettable Acre Determination
Animal Waste Management System
Page 2
Category 2:
J[ Your facility has been identified by the Department of Environment and Natural Resources
as a facility that may have overestimated the number of acres actually receiving animal
waste. Therefore, some or ail of your fields may be exceeding tale aCowable loading sates
set in your Certified Animal Waste Management Plan.
In order to resolve this issue, please contact a designated Technical Specialist to have him
or her conduct a Wettable Acre Determination for your facility. The Technical Specialist must
be one that has been approved by the Soil and Water Conservation Commission to conduct
Wettable Acre Determinations. Many Technical Specialist with the N.C. Cooperative Extension
Service, the Soil and Water Conservation Districts, the Natural Resources Conservation
Service, and the Division of Soil and Water Conservation have received this special
designation. You may also contact a private Technical Specialist who has received this
designation, or a Professional Engineer.
All needed modifications to your Animal Waste Management System must be made and
the Wettable Acres Determination Certification must be returned to DWQ within the next
180 days. If the needed modifications are not made and if the form is not returned within the
required time, DWQ will be forced to take appropriate enforcement actions to bring this facility
into compliance. These actions may include civil penalty assessments, permit revocation,
and/or injunctive relief.
Once a Wettable Acre Determination has been completed, a copy of the attached Wettable
Acre Determination Certification must be submitted to the address listed on the form. Please
note that both the owner and the Technical Specialist must sign the certification. A copy of all
the Wettable Acre Determination documentation that applies to your Waste Utilization Plan
must be kept at your facility. DWQ and the Division of Soil & Water Conservation Staff will
review all documentation during their annual visit of your facility. An additional copy must by
kept on file at the local Soil & Water Conservation District Office. Please note that if you install
or modify your irrigation system, a designated Irrigation Specialist or a Professional Engineer
must also sign the Wettable Acre Determination Certification.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Sonya Avant of our
Central Office staff at [phone] ext. 571.
Sincerely,
Kerr T. Stevens
cc: Wilmington Regional Office
Duplin County Soil and Water Conservation District
Facility File
Murphy Family Farms

1% Routine p Complaint p Follow-up of DWQ inspection Q Follow-up of DSWC review Q Other
Facility Number 0 Date of Inspection — --50
Time of Inspection ® 24 hr. (hh:mm)
Permitted 0 Certified 0 Conditionally Certified 13 Registered JE3 Not Operational Date Last Operated:
FarmName: ........ ../..)i.Y..!.:... iU!.!.._I.................................................................... County:............1)_4i............................. .......................
Owner Name:
Facility Contact:
Title:
MailingAddress: ..............................................................................................................
Onsite Representative:..........%:,):':1..y.dy.....................................
Certified Operator:
Location of Farm:
Phone No:
Phone No:
Integrator:.......kh,v.�?L,
Operator Certification Number: ..........................................
Latitude =0=, =" Longitude =• =' =11
_'
Desr uC
Cret)esrgt D-' Cu-rre-nturrenf:
S
_ ,
Ca acity-Po illation
Caacr_,PuaonctyPo ulatio'n'' '
Cwrne
Paull 'Cattle-.
_
❑Layer -❑ Dairy -
❑ Non -Layer .! ❑ Non -Dairy
❑ Other
Total Des'g�i_ Capacity
Total SSLW_
a= Number of Lagoons = ®
'.- ❑ Subsurface Drains Present ❑ Lagoon Area ❑ Spray Field Area '
Holding- is Traps-�
❑ No Liquid Waste Management System
Wean to Feeder
Qd
Feeder [o Finish
40 O
Farrow to Wean
0 0
❑ Farrow to Feeder
❑ Farrow [o Finish
❑ Gilts
❑ Boars
Discharges & Stream Impacts
1. Is any discharge observed from any part of the operation?
Discharge originated at: ❑ Lagoon ❑ Spray Field ❑ Other
a. If discharge is observed, was the conveyance man-made?
b. If discharge is observed, did it reach Water of the Slate'? (If yes, notify DWQ)
c. If discharge is observed, what is the estimated flow in gal/min?
d. Does discharge bypass a lagoon system'? (If yes, notify DWQ)
2. Is there evidence of past discharge from any part of the operation?
3. Were there any adverse impacts or potential adverse impacts to the Waters of the State other than from a discharge?
Waste Collection & Treatment
4. Is storage capacity (freeboard plus storm storage) less than adequate? ❑ Spillway
Structure l Structure 2 Structure 3 Structure 4 Structure 5
❑ Yes WNo
❑ Yes ❑ No
❑ Yes ❑ No
❑ Yes ❑ No
El Yes �No
❑ Yes No
❑ Yes kNo
Structure 6
Identifier: ��^^
Freeboard(inches): ...,,,,,_._..J,d� 9.................................................................................................................................................................................................
5. Are there any immediate threats to the integrity of any of the structures observed? (ie/ trees, severe erosion, ❑ Yes gNo
seepage, etc.)
3/23/99 Continued on back

Facility Number: 3 — b Date of Inspection
6. Are there structures on -site which are not properly addressed and/or managed through a waste management or
closure plan?
(If any of questions 4-6 was answered yes, and the situation poses an
immediate public health or environmental threat, notify DWQ)
7. Do any of the structures need maintenance/improvement?
8. Does any part of the waste management system other than waste structures require maintenance/improvement?
9. Do any stuctures lack adequate, gauged markers with required maximum and minimum liquid level
elevation markings?
Waste Application
10. Are there any buffers that need maintenance/improvement?
11. Is there evidence of over application? ❑ Excessive Ponding b(PAN
12. Crop type
13. Do the receiving crops differ with those designated in the Certified Animal Waste Management Plan (CAWMP)?
14. a) Does the facility lack adequate acreage for land application?
b) Does the facility need a wettable acre determination?
c) This facility is pended for a wettable acre determination?
15. Does the receiving crop need improvement?
16. Is there a lack of adequate waste application equipment?
Required Records & Documents
17. Fail to have Certificate of Coverage & General Permit readily available?
18. Does the facility fail to have all components of the Certified Animal Waste Management Plan readily available?
(ie/ WUP, checklists, design, maps, etc.)
19. Does record keeping need improvement? (ie/ irrigation, freeboard, waste analysis & soil sample reports)
20. Is facility not in compliance with any applicable setback criteria in effect at the time of design?
21. Did the facility fail to have a actively certified operator in charge?
22. Fail to notify regional DWQ of emergency situations as required by General Permit?
(ie/ discharge, freeboard problems, over application)
23. Did Reviewer/Inspector fail to discuss review/inspection with on -site representative?
24. Does facility require a follow-up visit by same agency?
25. Were any additional problems noted which cause noncompliance of the Certified AWMP?
u' Nd-vi6lhtiglis:0- dg£cWhdii g were itofe¢• dtWiitg this:visit' - Y:ou All- •e0iye fio fut•thQr,
coriesnoridence about his visit:::::::::::::
PAW a -
cc C
❑ Yes VNo
❑ Yes hrNo
❑ Yes t4 No
❑ Yes XNo
❑ Yes t<No
9Yes ❑ No
❑ Yes W No
❑ Yes &No
❑ Yes ❑ No
❑ Yes ❑ No
❑ Yes XNo
[]Yes ONO
t4Yes ❑ No
❑ Yes ONO
❑ Yes XNo
❑ Yes 'R No
❑ Yes ['&No
❑ Yes KNo
❑ Yes KNo
❑ Yes bdNo
ioYes ONO
sS( Ge� cc(/ S CC
Reviewer/Inspector Name
Reviewer/Inspector Signature: _ Date:

Facility Number:3 ad Date of Inspection n n•`-TL6
Odor Issues
26. Does the discharge pipe from the confinement building to the storage pond or lagoon fail to discharge at/or below KYes ❑ No
liquid level of lagoon or storage pond with no agitation?
27- Are there any dead animals not disposed of properly within 24 hours?
28. Is there any evidence of wind drift during land application'? (i.e. residue on neighboring vegetation, asphalt,
roads, building structure, and/or public property) .
29. Is the land application spray system intake not located near the liquid surface of the lagoon?
30. Were any major maintenance problems with the ventilation fan(s) noted? (i.e. broken fan belts, missing or
or broken fan blade(s), inoperable shutters, etc.)
31. Do the animals feed storage bins fail to have appropriate cover?
32. Do the flush tanks lack a submerged fill pipe or a permanent/temporary cover?
❑ Yes No
❑ Yes No
❑ Yes 1�No
❑ Yes KNo
❑ Yes P 'No
❑ Yes RNo
Additional Comments „and/or Drawings:..
L
�y
� s
I� & �'&l
"I Epp 4
�V4U e

State of North Carolina
Department of Envirom
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
Wesley Hairr
Hairr I Sow Farm
1188 VeachOs Mill Road
Warsaw NC 28398
Dear Wesley Hairr:
ITvFIDI !
JAN 0 6 2000 NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
December 30, 1999
Subject: Fertilizer Application Recordkeeping
Animal Waste Management System
Facility Number 31-200
Duplin County
This letter is being sent to clarify the recordkeeping requirement for Plant Available Nitrogen (PAN)
application on fields that are part of your Certified Animal Waste Management Plan.
In order to show that the agronomic loading rates for the crops being grown are not being exceeded, you
must keep records of all sources of nitrogen that are being added to these sites. This would include nitrogen
from all types of animal waste as well as municipal and industrial sludges/residuals, and commercial fertilizers.
Beginning January 1, 2000, all nitrogen sources applied to land receiving animal waste are required to
be kept on the appropriate recordkeeping forms (i.e. IRRI, IRR2, DRYI, DRY2, DRYS, SLUR1, SLUR2,
SLD1, and SLD2) and maintained in the facility records for review. The Division of Water Quality (DWQ)
compliance inspectors and Division of Soil and Water operation reviewers will review all recordkeeping during
routine inspections. Facilities not documenting all sources of nitrogen application will be subject to an
appropriate enforcement action.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Ms. Sonya Avant of the
DWQ staff at [phone] ext. 571.
Sincerely,
Kerr T. Stevens, Director
Division of Water Quality
cc: Wilmington Regional Office
Duplin County Soil and Water Conservation District
Facility File
1617 Mail service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recyded/10% post -consumer paper

Revised Arml 20, 1999
JUSTIFICATION & DOCUMENTATION FOR MANDATORY WA DETERMINATION
Facility Number S� -'I60
Farm Name: Z.-,. SC t„ -A
On-Site Representative:
Inspector/Reviewer's Name: k �
Date of site visit: 4 (a�19 C1
Date of most recent WUP: (lr
(�Z�­5 = 8_
Operation is flagged for a wettable
acre determination due to failure of
Part 11 eligibility item(s) F1 C22" F3 (4
Operation not required to secure WA
determination at this time based on
exemption El E2 E3 E4
Operation pended for wettable acre
determination based on P1 P2 P3
Annual farm PAN deficit: i2 S$ pounds
Irrigation Systems) - circle €: I&hard-hose traveler, 2_ center -pivot system; 3. linear -move system;
4. stationary sprinkler system w/permanent pipe; 5. stationary sprinkler system w/portable pipe;
6. stationary gun system w/permanent pipe; 7. stationary gun system w/portable pipe
PART I. WA Determination Exemptions (Eligibility failure, Part II, overrides Part I exemption.)
E1 Adequate irrigation design, including map depicting wettable acres, is complete
and signed by an I or PE.
E2 Adequate D, and D2/D3 irrigation operating parameter sheets, including map
depicting wettable acres, is complete and sioned by an I or PE.
E3 Adequate D, irrigation operating parameter sheet, including map depicting
wettabie acres, is complete and signed by a WUP.
E4 75% rule exemption as verified in Part III. (NOTE:75 % exemption cannot be
applied to farms that fail the eligibility checklist in Part If. Complete eligibility
checklist, Part II - F1 F2 F3, before complefing computationai table in Part III).
PART II. 75% Rule -Eligibility Checklist and. Documentation of WA Determination
Requirements. WA Determination required.because.operation fails one of the.eligibiiiry
requirements listedbelow:
F1 Lack ofacreagewhichTesultedinnvermpplication�f- astewater_(PAN) onspray.
fields) accordingtofarm's Jesttwo _years nfIrrigation7e-coms.-
F2 Unclearjllegible,-or lack of information/mar).
F3 Obvious --field limitations -(numerous itches;lailurefo:deductlequired:.._
buffer/setbackmcreaae;-or25%:ofiotal_-acreaoeddentined:in-]-,AWMP includes
small; -irregularly -shaped fields -fields less than-5 acres for travelers -or Iessthan
2 acres for. stationary sprinklers).
F= WA determination required because CAWMP credits lieid(s)'s acreage in excess
of 75% of the respective field's total acreage as noted in table in Part III.

Revised .4nri1 20, 1999
Facility Number
Part III. Field by Field Determination of 75% Exemption' Rule for WA Determ• £
TRACT
NUMBER
F
FIELD
NUMBER''
ma on
TYPE OF
IRRIGATION
SYSTEM
TOTAL
ACRES
CAWMP
ACRES
FIELD
COMMENTS'
La ct
j
I
I
j
I
I
Fr i n ruirneaco�
ti a
I
I
I
(
--- — —•• ••��•a •4 Pu a20sm, ur-punu numbers -may be used in place of field numbers depending on CAWMP
and type of irrication system. If pulls, etc. crossmorethan one field, inspectodreviewer will have to combine fields to
calculate 75% field by field determination for exemption; otherwise operation will be subject to WA determination.
FIELD NUMBER= - must be clearly delineated on -map.
COMMENTS' - back-up fields with CAWMP acre2ee-exceeding75% of its total.acres and havingreceived less than 50%
of its annual PAN as documented in the farm'sprevious two years' (1997 & 199B) of irrication-records,-cannot serve -as the
,sole basis -for requiring a WA De+termination:_Back-uplieldsmustbenoted in the-commentsectionand mustbe accessible
by irrication system.
Part IV. Pending WA Determinations -
_Pi Planlacks
P2 Plan revision maysatisfy7.5% rule based on adequate overall PAN deficit and by
adiustina all fieldacreageto below 75% use rate
P3 Other (ie/in process of installing new irrigation system):,

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
August 17, 1998
Wesley Hairr
Hairr I Sow Farm
1188 Veach's Mill Rd
Warsaw NC 28398
AT
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
RJECEIVED AUG 2 1 190,
Subject: Certificate of Coverage No. AWS310200
Hairr I Sow Farm
Swine Waste Collection, Treatment,
Storage and Application System
Duplin County
Dear Wesley Hairr:
In accordance with your application received on April 13, 1998, we are forwarding this
Certificate of Coverage (COC) issued to Wesley Hairr, authorizing the operation of the subject animal
waste collection, treatment, storage and land application system in accordance with General Permit
AWG100000. This approval shall consist of the operation of this system including, but not limited to,
the management of animal waste from the Hairr I Sow Farm, located in Duplin County, with an animal
capacity of no greater than 400 Wean to Feeder, 1000 Feeder to Finish, and 3500 Farrow to Wean and
the application to land as specified in the Certified Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations
as specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General
Permit or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS
143-215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This
request shall be made within 30 days of notification by the Division.
This COC is not automatically transferable. A name/ownership change application must be
submitted to the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the
right to apply for an individual non -discharge permit by contacting the engineer listed below for
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Certificate of Coverage AWS310200 ..
Hairr I Sow Farm
Page 2
information on this process. Unless such a request i"s made -within 30 days, this COC shall be final and
binding.
The subject farm is located in the Wilmington Regional Office. The Regional Office Water
Quality Staff may be reached at [phone]. If you need additional information concerning this
COC or the General Permit, please contact J R Joshi at [phone] ext. 363.
`,
-4A. Preston Howard, Jr., P.E.
cc: (Certificate of Coverage only for all cc's)
Duplin County Health Department
Wilmington Regional Office, Water Quality Section
Duplin County Soil and Water Conservation District
Permit File

1
1
2.
State of North Carolina tt;<='EC�
Department of Environment and Natural Resources ��''C14/: ,
Division of Water Quality 4pq f
Non -Discharge Permit Application Form 1996
(THIS FORM MAY BE PHOTOCOPIED FOR USE AS AN ORIGINAL) y�`gC6",
General Permit - Existing Liquid Animal Waste Operations " �4��ry;,
The following questions have been completed utilizing information on file with the Division. Please a1
review the information for completeness and make any corrections which are appropriate. If a 4,;
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
GENERAL. INFORMATION:
1.1 Facility Name: Hairy I Sow Farm
1.2 Print Land Owner's name: Weslev Hairy
1.3 Mailing address: 1188 Veachbs Mill Rd
City, State: Warsaw NC Zip: 28398
Telephone Number (include area code): 910-293-3036
1.4 County where facility is located: Duplin
1.5 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a
copy of a county road map with the location of the farm identified): Take US 117 N to Warsaw; at stop light, turn Rt. onto
NC 24E to edge of town where NC 24 and NC 50 merge; take SR 1300 E for 1.4 miles; turn Rt. onto SR 1305 for 1.4
miles; go thm intersection of SR 1305 and SR 1301 onto SR 1307 for 3.0 miles to fans entrance on Lt. Farm about 0.7
miles off SR 1307.
1.6 Print Farm Manager's name (if different from Land Owner):
1.7 Lessee's / Integrator's name (if applicable; please circle which type is listed): MurphyEFamilyEFarms
1.8 Date Facility Originally Began Operation: 01/01/93_ _
1.9 Date(s) of Facility Expansion(s) (if applicable):
2.1 FacilityNo.: _31_ (county number); 200 (facility number).
2.2 Operation Description: Swine operation
-Tean to Feeder
Feeder to Finish
Farrow to Wean
4900- Certified Design Capacity
Is the above information correct? Q yes; F7no. If no, correct below using the design capacity of the facility
The "No. of Animals" should be the maximum num er or which the waste management structures were designed.
Type of Swine No. of Animals Type of Poultry No. of Animals
0 Wean to Feeder 0 Layer
0 Feeder to Finish 0 Non -Layer
0 Farrow to Wean (# sow) 0 Turkey
0 Farrow to Feeder (# sow)
0 Farrow to Finish (# sow)
Type of Cattle No. of Animals
0 Dairy
0 Beef
FORM: AWO-G-E 1/26/98 Page 1 of

2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): 103.9 ; Required Acreage (as listed in the AWMP): 103.9
2.4 Are subsurface drains present within 100' of any of the application fields? YES or lease circle one)
�. 2.5 Are subsurface drains present in the vicinity or under the lagoon(s)? YES or NO lease circle one)
2.6 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, NRCS�Standards, etc.) (Swine Only)
Y( RCL� S br NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited? \k°13
What was the date that this facility's land application areas were sited? q3
3. REQUIRED ITEMS CHECKLIST
Please indicate that you have included the foliowiiig required items by signing your initials in the space provided next to each
item.
Applicants Initials
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations; 'A
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied; x i
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit
application for animal waste operations.
The CAWMP must include the following components:
3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application.
3 . 3 . 4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application field.
3.3.8 The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.3.10 A site schematic.
3.3.11 Emergency Action Plan.
3.3.12 Insect Control Checklist with chosen best management practices noted.
3.3.13 Odor Control Checklist with chosen best management practices noted.
3.3. i4 Mortality Control Checklist with the selected method noted.
3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.)
If your CAWMP includes components not shown on this list, such as an irrigation design,
or site evaluation, please include the additional components with your submittal.
FORM: AWO-G-E 1/28/98 Page 3 of 4

Facility Number: 31 - 200
Facility Name: Hairr 1 Sow Farm
4. APPLICANT'S CERTIFICATION:
i
I, I.'25,2 iT , r ✓
this application for L ' rr' —I_ Spy c— r "v
has been reviewed by me and is accurate and complete to the best of my knowlei
application are not completed and that if all required supporting information and
package will be retumed to me as incomplete.
Signature _
5. MAN
1,
(Land Owner's name listed in question 1.2), attest that
(Facility name listed in question 1.1)
tand that if all required parts of this
are not included, this application
�a"
CERTIFICATION: (complete only if different from the Land Owner)
(Manager's name listed in question 1.6), attest that this
application for (Facility name listed in question 1.1)
has been reviewed y me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned as incomplete.
Signature
Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
FORM: AWO-G-E 1/28/98 Page 4 of 4

DIVISION OF NVATER QUALITY REGIONAL.OFFICES (1/98)
Asheville Regional WQ Supervisor
59 Woodfrn Place
` Asheville, NC 28801
[phone]
Fax [phone]
Avery
Macon
Buncombe
Madison
Burke
McDowell
Caldwell
Mitchell
Cherokee
Polk
Clay
Rutherford
Graham
Swa;_-
Haywood
Transvlvania
Henderson
Yancey
Jackson
Fayetteville Regional WQ Supervisor
Wachovia Building. Suite 714
Faveneville. NC 28301
(9i0)486-1541
Fax [phone]
Washingon Regional WQ Supervisor
943 Washington Square Mall
Washington, NC 27889
[phone]
Fax [phone]
Beaufort Jones
Berrie
Lenoir
Camden
Martin
Chowan
Pamlico
Craven
Pasquotank
Currituck
Perquimans
Darr
Pin
Gates
Tyrell
Greene
Washington
Hertford
Wayne
Hyde
Mooresville Regional WQ Supervisor
919 North Main Street
Mooresville, NC 28115
[phone]
Fax [phone]
Raleigh Regional WQ Supervisor
3800 Barrett Dr.
Raleigh, NC 27611
(919)-571-4700
Fax [phone]
Chatham
Nash
Durham
Northampton
Edgecombe
Orange
Franklin
Person
Granville
Vance
Halifax
Wake
Johnston
W=en
Lee
Wilson
Wilmington Region. WQ Supervisor
127 Cardinal Drive Extension
Wilmington, NC 28405-3845
[phone]
Fax [phone]
Anson
Moore
Alexander
Lincoln
Brunswick New Hanover
Bladen
Richmond
Cabarrus
Mecklenburg
Carteret Onslow
Cumberland
Robeson
Catawba
Rowan
Columbus Pender
Harnett
Sampson
Cleveland
Stanly
Duplin
Hoke
Scotland
Gaston
Union
Montgomery
Iredell
Winston-Salem Regional WQ Supervisor
585 Waughtown Street
Winston-Salem. NC 27107
[phone]
Fax [phone]
Alamance
Rockinghafn
Alleghany
Randolph
Ashe
Stokes
Caswell
Sum
Davidson
Watauga
Davie
Wilkes
Forsyth
Yadkin
Guilford
FOR-1%1: AWO-G-E 1/28/98 Page 4 of 4

n..-'crrT10U
L: I �—
:animal Waste Management Plan Certification
S
(?le'�ie (voe or odnt all infurmadttn t!:1t d0a: not reuuire ❑ sienatu,_"
t94i>
a t.
General Information:
Name oc Farm: Ha re- t 5o.;D roe rn
ow-e-7(s) Name: 1,3es le-j tat'- / F`or:e iNo:C90)d93
-303(o
.Maiiins Address-IM Veor,n a fAM EJ 040), A C- a439 ff
Farm LO CGr[OrI: County is located In:
U 1 „ � t l•
• Lath=de and LOn2icude3z �3 �33 / �� C)1 \ C, Integrator: r
r•/v�
Pleas: art3C1 a copy oc a county road !nap wild JOC'StlOn idd-Uihed am' descrlCe Jeiott' ( e sG2Cthc: road
names, directions, mile?osLetc.): NG,\ e- rt_l
onto t1­214CE
-}s 6 P O� {p,,1, i-,�Ye'_ t\L�,l L r\Cs0 N,2 o e IA- V_n tza0 �'ot 1.5
W lez. •�-.�cin
ph-Fo t p for l.o r-.'le r rt t`>- nv�Tll S>T, t"ZUS r kA w.le Gn46"
'taiwuJhantS
+-..r.-5 c�,ze���3.0 •1es .�+.-. ev,k•.c.rxe m e � .
Try-e of in>-
h'o. o% =nimais
Trpe o.f ?otdrr-- Na. o%Aedircals
t t?e of C�r!: .Fa. of =aitrta(s
'100
J Lacer
= D
ir e .Z, to Finish
000
J pullets
-'-0--
w to tVe_n
3 00
-`--w co .^. sh
Orher Type of _ :zScoc
y'tu:_,_rc'.=.;ti;rcIs:
C_us
— =ca ,
.-c:_ A.vaiiabte for Aoclic__c
/
.9 Required Acreage' 103.
`uaber o__goons / Sto_ge ?-:ds:
r
IotCapac- y Ot_ Cubic ?vet
-_e subsc__ca drains 7reseac on _ f_ YES or � (p!2=Se e_c!e one)
If = Sz-- nHbsurf„c„d.--ias-_.n,;n cbt ar i of Lie LAGOON Cr SPRAY FIELD (ple-;. _ one.'^.}.x�„„.yw
Owner- / Tanager Agreement
I (we; verify c!tac all the above iafonation is cueec: and tv;U be u^date•: upon chan_inI. (i :e: undo gad he oee goon
_-d ;^a .,eeance orocedu-s esu�lishe•d in the aooroved anima! • azce c'_a^_emeat plan for e fa.—" named above and
.:npiemenc t .ese procedures. l (-e) :.low that anv excanswn to Lbe existing design Cava tv at the waste treamtent and
stor_ea s-:scenl or COaSz:-ac_On of ntw facilities wit! require a new eertiiicadon to be <-ui'mtaed to the Division of
= 1.... •�=tal Nlaname.m.nt before uie new animals are stocked. 1 (•.'-e) understand �,at tea= Host be no dischaae of
=:;=—i. waste from the storage or a"Headon System to S•.tr pace c: ace. Of the >i.'.:e a? IhrouS•II a man-made
con eya:.ee or from a scorn a :tat (ess severe chan the '_5-yew. '_hour storm and oher_ g ust not be runoff trot,. d1e
cciicacicn of anima! caste. '! (i�'e) understand that run-off of po(luulcs from lounsi. sd heavy use area must be
nip. -i_ea using ceehnicai scarc.as de•:elueed by tars Nacu =1 Resotrces Consenadon :en:cc. The aucruced plan will be
- `f: farm and at the of ce of the local Soil and `.VNace: Curse^aeon Dist. I (r -) :cow hat any modidr_rion
• rausc aeeroced by a tech. r1 scecialist and subm!tced to _Jc Soil and Nate: Cer_e:c_cor, District prior Cc
.vieme :ecun. A change in land ownership requ:res wM= roc =cacon to DELI or a Ova c: =C'_don (if the aoeruced
pia . is c_ ^ oed) within 60 days of a dde transfer.
Name of Land Own.r: No1r1
Sign= ure: X
ttiane of Manager(a dittereattront ou'aer)=
Si^narure•
August 1. 1997
Date: � z-- i ``1 _1
Date:

Technical Specialist Certification
I. ,s a technical specialist designated by the North Carolina Soil and Water Consen•adon Commission pursuant to 15A
NCAC c;: .0005. 1 cer.ifv that Ma animal waste management system for the farm named a'tove.has an animal waste
manage= enc plan that mega r-
or exes standards and specifications of the Division of Em ironmental lanagemenc
(Dc.N,i) as specified in 15A NCAC 2H.0217 and the USDA -Natural Resources Consentsdon SeMct (NRCS) and/or the
Nord Carolina Soil and Wacer Conser�adon Commission pursuant to 15A NCAC 2KO211 aid hA NCAC 6F .0001-
.0005. The foilowing elements ar_ included in the plan as applicable. While each categori desiscaces a technical specialist
who may sign each certification (SD. Si. WUP. RC. 1). the technical specialist should only c-:- y parrs for which they are
technically competent.
II. Certification of Desig n
A) Collection. Storage. Treatment System_
Check Nc_ acDropfiare box
M( isring Facility without retrotit (SD or NVL P)
St. rage volume is adr.uate for operation capacity: storage capubility consi tine midi waste utilization
ruuuirements.
—1 New. exnanded or relratit ed Facility (SD)
animal waste smrage and ataunenc structures. such as but not limited to collection seems. lagoons and ponds.
have been designed cc tn.t: or exceed the minimum Stan "Forand speciti=d0ns.
Name of Technical Soecialist(Please Princ): K,,-,-, Lie Jer-�O
Dace Work Com iele+ ID11 / 17
Acdr_Ss (A�eac : N,11 C S Pone\o.fgro)1fl9 gin e'vW556
Sid^=r_re: Dare: / ahM 7
B) Land 400 icT a�Site (W P)
plan provides for min.'^nm secaradoas (buffos): ade;u_ce amount of land for mom' adlizadon: chosen top is
sui_Ole for waste managem:e::c: hydraulic and nutrient, loading races_
Narne of Technical Specialist (Please Princ): I e✓bc
Dace Worlk Compie:ed: Il /I 14 7
AddreSs (Agency): Phone
,. o.:
�/-� r1
C) Runof9CanfFM9-'ff(
Cyrec.: rite anoroor art box
agility without --terror lots (SD or WI P or RC)
This facility dces not cane_n anv a icerior lots.
Facilirr with esteror foes (RC)
Methods to mimmize ce run off of pollurnts from lounging and heavy use arts 5a:: been designed in
accordance with ceaair_� standards developed by L RCS.
Name of Technical Specialist
Addr_ss (A
ate Work Comole.ed:Ja111`I 7
AWC -- k,4;4

D). Aunlication and HandlinaEouiornent
Check tire ap'cropriare box
ia•in mar-- nndina N-ility with etistina wide nl.ni icadnn apuinment (WI;? or 1)
Animal waste aoolicadon equipment sceciticd in the plan has been either field calibrated or evaluated in
accordance with existing design chars; and ables and is able to apply waste as aec:ssary to accommodate the
waste management plan: (existing aoplicacien equipment can cover the area the plan ac rates not to
exceed either the scecified hydraulic or nutrient loading maces. a schedule for [Laing of applications has bee -
established: required buffers can be maintained and calibracon and adjusmient gold=ceir- contained as pan of
the plan).
New e nand or ­iSi'q fncilite wichnic eti;i•ina wnue ,onIicrcion epuinrnent for s2nv irigotion. (1)
Animal waste acoliadpn equipment specified in the pt, n has been designed to a?ph• waste as necessaiv to
accommodate the waste management plan: (proposed application equipment can cover the aura required by the
plan at races not to exceed either the specified hydraulic or nutrient loadini rates; a scheduie for timing of
aoolicadons has been esabl'uhed: required butre s can be maintained: calibration aad adjusanent guidance are
contained as oar. of the plan).
,,a v errindedor e7t,sting ftcility without etiscing w-nsce aoelic•ition eouion-nt For fond mreading not using
smarm• irrfgntitm. (W ? or r)
Animal waste apeliadon equipment specited in the plan has been selected to apply waste as necessary to
accommodate the waste management clan. (procosed aoelieardon equipment c_. ovz: the area required by the
plan at rates aqc to es red either the specified hytimaulie or nutrient loading _tz<_: a schedule for timing of
acolicadons has beea esabiished; required buffets can be maintained: cadbrdun =d adjuseienc guidance are
contained as par, of tee plan). (l j
Name of Technical Specialist (Please P.010: rat
:i: _.:cuGn /' "_ / Date `S/oiX
ACCre55 (A 4e^",• : CSC^ e \J.:
Si�-a__re Dar-: IVI/47
E)
e waSm management Sian. for this fac;iir+ irdudes a W as:e N(anagement Cdcr Concel Cbh st an Inset:
Control Chec'v st- a Mcr=lief Vanasemeat Chec'aisc and anEmergency Action ?'_^. =oures of both odors 'and
insec:s have been e':aluated with respect to this site and 'nest Management ? _r'r_s co )[ nLnize Odors and Besc
3lanagemenc?rac:ices to Concol Insets bay-- been selected and included in chl- ivy» pi='ta tment plan. Both the
Nicnalicv Manaataez.?!an and the Emergency Action ?lane arie eorplece and Can re in?ie_ etued by this faeilir:.
l t 1 t r
Narrat of Technical Specialist
Address
work CJmple:d: t �l I �9 i
-7
F) Wr.rteii Notice New or Expanding S%%ine t' arm
The folios g signature blocl is only to be used for new or expanding Sine farms th=t begin construction after June
.1, 1996. the facility was built before June 21. 1996, when Nvas it constructed or last
I (:-e) ce___y that 1(we: have a:rempced to connc: by ten red ml inp
i a adjoins ace yo::;.ea and It property owner
who a ,,, prccenv locaed across a public [pad, street or highway f �m this new ore :can' ! ; s'^ ne :an• The notice was
in ecr..piio .ee wi h the requL_-meats of NCG5 106-305. A copy of ce notice and a list of'`e pipe! ow'nets nodded is
accc� cd_ .
Name of Land Owner:
Signature:
i ame of Manager (if dif erect From owner):
Signature:
Ass'C -- AuzLL t 1. 1971 3

IIL Certification of Installation
A) Collection. Storage. Treatment Installation
-iety. e:Coanded or retrontted facility (SI)
Animal waste scoraee and treatment structures. such as but not limited to laseons areal ponds. have been installed
in accordance with t~e approved plan to meet or e.-ceed the minimum srndids L.d specifications.
For e:istfn3 facilities without retrofits, no certification is necessaq.
Name of Technical Specialist (Please Print):
A.MHadon Dace Work Coctpleted:
Address (Agency):
Signature: D``':
No.:
B) Land aoolication Site (NNIP)
Cheek fire anpropriare bat
—zT he cropoin; system is in place on all land as specified in the ari.:lLl waste management plan.
:1 Conditional Auoroval: all required !and as specified in the plan is c!e_ d fcrciantia?_: the t'ropping system
as SpeciL:Cd in the 'w2 ze u0iZadon plan has not been established and the Own= has committed to establish the
:e�e3tion as sceci`ied ire. the plan by (month/dayiee-i: c`e proposed eovzr zap is
aotiropriace for =rapiiance with the was;zuriliz_don p(i-i.
Also ch e_!%- Chis box if appropriate
if the c -,ccin_ system as specified in the olar: can nor be established_ on -c-+(v c!e_^^_ land within 30 days
of this ce<_nc Lion. ce owner ha com^.icmd ro e ablish an inte^r.. c. o fcr erosion Control:
Name of Technical Specialist (Please Print): v--
rinn AA r, / /1 / Date Work CoGaetec:l�/l19�
ddress (Agency :
Sisnatnre:
T'nis follos inaa g tote bloc; is oniv to be used when the box for condironai aooroval in III. B
above h been checked.
I (we) czn_ify that I (we) have comrnced to establish the cropping system as speeried in mv(our) waste utilization titan.
and if aco vorate to establish he interim crop for erosion control. anal will submit to DE1[ a ve.^'fica on o(comolarion
f—jm a I tc�nicai Specialist wit .in l: calendar dayss following Lit!t3ce specified in the e.rdicu c ani6r_cion. I (we)
Malize that failure co submit this ven:icadon is a violation of the w-sce roan-gemenc pLa acd •will subje'a me (us) to an
enforcer:enc action from DELI.
Name of Land Owner:
Signature:
Name of ?.Tanager (if different from
Si.-narnre
Date:
Date:
A\yC -- Aucusr 1. 1997

C) Runoff Controls from Exterior Lots (RC)
Facility with exterior lets
ttctlwdi to minimize die run off of pollumnti Crum lounging and heav}' use ;.real ;are hr_n itunlled s specified
in the plan.
For facilities without exterior lots, no eerrffieadon is necessan•.
Name of Technical Specialist (Please
Afniiar_0
Address (Ageacv):
Work Comoi-d-
Phone \o.:
D) Aoolication and Handling Eauioment Installation (`YUP or I)
Check titroanote block
_ u oAnimal waste application and handling eauipnienc specified in the plan is on site and radc for use:
calibration and adiusanene materials have been provided to die owners and ar.• C-ont ;red as pan of the plan.
Animal waste acoiir_don and handling equipment spe--ifwd in die plan has not beea installed but die owlier
has proposed It sin_ or third party application and has provided a signed c^nr_cc equipaient specified in
the contact agrees with die mquirement> of Lhe plan: required buffers r1 'ct aiaiat:indd: calibration and
adjustment guidance ance have been provided to die owners and are contained as of We plan.
Conditional approval:.�limal waste application and handling epurpcent spe ned in the plan has
been pure: axed and will .be on site a.1d insra.led bF (cercl avfrear): there is adequate
storage to hold the waste until the equipmeac is ins.: tied and until the o_ c c= be land applied in
accordance wit!: dit cnopoing system contend in Lhe plan: and calibr_tica adluseaent guidance have
been provided to We owners and are contained as pa.` of the plan.
Name of Technical Specialist (Please
Afnlia=er. MFF % Date Work Co=le_d: fall /�
Address ( ): / Phc.=.:.No.:
Sisr.a =r_: Dom= talll9-7
The follow ng st_nature block is only to be used when the box for conditional approval in III D
above has been checked.
1 (•::e) c_.-=f [liar I (we) have commined to Curcnase the an ma waste aoa6cader. L-d y_rdliag e•.uipment as
specked in my (our) waste managt.rnenr plan and will submit to DELI a vernier' ic. of deriver: and installadon
tron a Teclsscal Soeci2tist w �dn L calendar days following Lhe ace specified in c:e xr.C¢onal cer�iticadoa. I
(wei reaiize thac failure to submit m:s venficadon is a •:io1a[ion of ate waste mirage^eat 71a.1 and will subject me
(us) to an enforcemear action ±om DE:N'l.
-Name of Land Owner:
Signature:
Name of Manager (if different from owner):
Signature:
Date:
Date:
E) Odor Control. Insect Control and Mortality Plana^einent (SD. SI. NV P. RC or D
tie'"`eC's to control odors and insects as specified in Lie Plan have been inst=lle� and are oce:.itionai- Tne
morr^_ticy u.=agement system as specified in ta`.e Pl= has also Feel fi15L led and Is Cp'=C,Cn'at.
Name of Technical Specialist (Please Print):
AftH iacc.n. MFF / 11
Address (:
Sign_:ore:
Work Con-:7ieted: 1 a/I1=-
Phone \o.:�
Date: ) a I I / 97
A%VC --

Please return the completed form to the Division of Water Quality at the folloiin; address:
Department of Environment, Health, and Natural Resources
Division Of Water Quality
Water Quality Section, Compliance Group
P.O. Box 29535
Raleigh, NC 27626-0535
Please also remember to submit a copy of this form along with the complete Animal Waste
Management Plan to the local Soil and Water Conservation District Office and to keep a copy
in your files with your Animal Waste Management Plan.
VVC -- Aug t 1. 1997 6

Producer: Qe5IcI Hoa rr - - Hc,-% Y'I Sew `
Location: I IV ✓e J- s IA:11 Rd.
4�a.•r,.a,i✓c a439�
Telephone: (310)a!-13 - 303(.
Type Operation: Q-der-fihlg 4,
-
Number of Animals: 350 0 [$:0 s
(Desig= Canaci4') 100 O T st, I
400 ^NrO G/
The wale from your {acuity m„ �r e land aDulied at a specned rte to pr. gent
p olution of surface and/or _roundwater. The plant nutrients in the waste should
be used to reduce the z^ount of commercial fertilizer required for the crop; tie fields
I the waste is to be applied _ This wale Utilization, plan uses nitrosw
=u :eat• Waste should be anaivmd before each application cycle. An n_1;an tens are
—ongiv encouraged;o mat au plant nutrients can be beIanced for reaL.'c •: -
or ag
r_op to be grown. -
Several factors are ignorant in imnlemeatiiag your waste trtiization plan it order to
the fer¢iize: vaiue of the waste and to ensure that it is applied:
e`ZormenrallvsaL"ntzAlways apply waste based on theneeds of �e -,00 to be
=owa and the nutrient Conte: of the waste. Do not apply more nitrogen crop
c� L :iize. Sou types ate inrportant as they have aiye:eat infiltration rates _
, aca�g
Potentials, cation escaan_e Capacities, and available water holding capac=es Normally
WaS.e Baal not be applied to Ind eroding at greater than 5 tons per acre tie: •:en-. W-rth
�_ tic ial precautions, ware may be applied to land er odn= at up to 10 to per ac:e per
yea:. Do not apply waste on sartrated soils, when it is ra;nhag, or whey tie :ice is
f--ozeu- Either of these conditions may result in nmoz to surface water whir is not
alow'ed under DEM rez.Katioas. Wind conditions should also be considered to avoid drift
aad downwind odor probleas. To maze the value ofnutrients for Croo production
anc to reduce the poten al for pollution, the waste should be applied to a Fcw sg crop or
applied to bare ground not more than 30 days prior to Ia tt g•
" P P Injecting tag -,vasze or
(':ckyaa will conserve nuclear and reduce odor proble=q.
i ne esizaated acres needed to apply the animal waste is based on typical nc�=t content
for tHis rvPe offacilir:. Ac;ea-a requirements should be based on the waste a_+h
rot or-, from your waste r..anagement facility. Attached you will find infor_=Cn on
prop er sampling technieues, preparation, and transfer ofw•aste samples to 6e lab for
a a. %ss.
Trys •-waste ucli=don play, ifcarried out, meets the requirements for comvIi=ce w, h 15A
;\ C AC 2ri.0217 adopted by the Ea,ironmental Nfanase"ieat Commission.

o - zv:l
I = d135o ia/� s
006 x(4 . _ ��
0o animals X.od ant.) wastelanimal/year = b (a=.) wastetyear.
Amount of Plant Available Nitrogen (PAS Produce3 Per Year
350o xS. `I = Iq,q oo
xa.3 a
loon _ I
- �oo
Lloo animals X-1 lbs. P.4N/animal/year = 19 a lbs. PAAV/year. (PAN from N. C. Tech
Guide Std.633) "foTAL :alla9a-WPAN/%cgs
Appiymg the above amount of waste is a big job. You should plan time and have
appropriate equipment to apply the waste in a timely stunner.
The foIlowiag acreage wM be needed for waste application based on the crop to be grown
and surface application
%c ie 1: ACRES OW2', ED BY PRODUCER
1=ac Feld Sou Crop Lbs. N Acres Lbs. ti '.Month of
No. Tune Per Ac. * Utilized ouliczdon
I HA;ri I 11 Ir✓�A Itohca� I I'iLi l y -7
IA
.�:rr•
I I6
1 Aµ
I W
I
Og
13.3
135Co 1
I /O
I II,J
I A
A
ISa
b� I
7
i1
18.0
600 1
90"e-
1 1�
I
o
I
ea sl
I
I
I
I (o
to I
113
I .a1r
11`I
Wo •Au
Is
4..s
s
.-1
I I
This Nis froth animal waste or./v. If nutriet`zcr
fey^-�_-r. are applie2 thry tr_es: be accounted for.
e^ oec-:arom
'A L
5 70
rote othersources such as con=-=czl
N nutst be based on realistic vield
NOT: The applicator is cautioned that P and K may be over applied while tneetiag the N
requirements. Beginning in 1996 the Coastal Zone Manage, Acf will requirefarr rr, in
so nce eastern counties of North Carolina to have a nutrient r: canagement plan that addresses
c!! n:ta.'erts. This plan only addresses Nirroger`

Tablet: ACRES WITHAGPEF-NM NLTORLONG TERM LE.ASr-
(?S, ement with adjacent landowner rnrst be attache
(Required only if coerator does not own
adequate land (see Required Soe._ ,ficadon 2])
Tract Field Soil Crop Lbs. N Acres Lbs. N V. mA f
' SeeJcoozotejarTcblel.
Totals from above Tables
Acres Lbs. N
Utilized
Table 1
Table 2 c l. o I, a,► 9 5
Total L io `l 1 a I
Amount of aced I al 3,?3,.
SuiphLs or efi - S0 ti
NOTE= The Waste Udli; adon Plan trust contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient rich and will
require precautionary measures to prevent over application o�rnutrients orother
elements:
3

I-e
Table 1: ACRES (3VX-NZEI2.BY PRODUCER
Tra= Field Sou Crop Lbs. N Acres Lbs. N Month of
No. Dme Per AcA--I:....:,...
I A-A
I cJticak I
lay
1 S•o
I as
a�u uu�auuu
1:5 A..;
l a
3
H
A-a.R I W L at- I
I AwR I ZI,+
A -PS I ,� I
a 5
low
I0�
1
1 -7. o
I . a
5
f (o
i5(.
- A
I -A
1 S-A
A,9
I QL.s I
0 r
I-7.a
C
IS -A
5 �ksov.
7
IR.P,
I Au
1 4 I
I
1017,
I oY
1 -7. 0
1 -7.0
1-756
6
15 A
I S- A
4
1Li&
1 Wry.+ I
/20
1 TO
l 5qQ
I-
1 9
1 LL B
I !,N,,o-I
I a
I -7. o
1 8110
I -A
o
f i
I -
S ..,-, I
Cif
I
1 'f75
I7—c-
I1,4
W.- -HIS
6e.1
95 1
-7.0
1 -6(a5
I p -A
a o
I
I
i 1
-7A I
o
f S -)b
1(Y-A .
L4
I
I S y,s 1
-75 1
7.o
I
1 T-A .
1fl
Ls.460,s I
i 1
-1.0
l 6a5
1-A
I A,R
IS1,6eA. I
1
1.0
I F5 95
I A A
a Eso-
1 -I
1 A
1 s, 6.�z 1
-7I
�.O177
l a 5
T �Cso
I 'R
1 B
IS I
0 I
E
I �3
-A
ck
I q
I L -6
LS. be. 1
a I
.o
I 3
'-A
I
I
I I
I
I
i
I
I
I 1
1
I
!
I
I
I I
I
I !
I
i
I I
I
I 1
I
I
I I
f
I !
I
I
I I
I
I i
I
I
I I
I
I I
I
I
I I
I
I i
I
I
I I
I
I
I
I
I I
I
I I
I
I
I I
!
I I
I
I
I I
I
I I
I
I
I I
I
I I
I
I
I I
I
I i
I
I
I I
I
I i
I
I
I I
I
I I
I
I
I I
I
I
I
I
I
I I
I
I
I
1=
I
I I
I
I
I
I
I
I I
!
I
I
I
I
I I
I
I
I
I
I
I I
I
I
I
I
I
I I
I
I
!
Total - I (-I.O 11�1'15 I

See artached map showing the fields to be used for the utilization of ware water.
Application of Waste by Irrigation
Field Sot? Type Crop Application AnoLcaaoa
�r -
=— -.i3L is N0'I-\c="n=s-ti`3'!LZ2=C--i�_ON,
e o r.
`= our facility is deald:or5L-days of te=orary sorage and the tenor_-- .ore
s be removed on the average of once eve_-y�_MONTHS. In no should
t he volume of was-,.- beiag soredin your structure exceed Elevation S= I Ls
J
Cail the local Natural Resources Conservation Service (formerly Soil Cersv x .•cn
or Sot? and Water. Conservation Dis,ict office a_rter you receive t_e «se
z`al� ss report for asisance in determining the amo„-,t per acre to arviv and *tee proper
appiication rate prior to appirmg the waste.

REQUIRED SPECEFICATIONS
L Animal waste shall not reach surface waters of the rate by runof; drik manmade
conveyances, dire: application, or direct discharge during operation or and
application. Any ducaarze of waste which reaches surface water is prohioa d
2. There must be doaimentation in the design folder that the produce: either owns or has
an agreement for use of adequate land on which to properly apply the ware. Ifthe
producer does not own adequate land to properly dispose of waste, he!she Shan
provide a copy of an agreement with a landowner who is within a reasonable
proxmnty, allowing himilier the use of the land for waste ap
plicatioiL It is the
resu onsibrlity of the own of the facility to semare an update of the Wave Utilization
Plan when there is a change in the operation, increase in the number of
method of utiluatioa, or available land-
3- ?2 `Waste shall be applied to meet, but not exceed, the nitropza _eds-5orralistic
(Zop yields based on cod -.ne,available moi=are, historical data, cl==h. corm OILS,
a=d level ofmanagem=_ trless there are reT,7=-*ons that restrict ire rare o-
aop.lication for otber au eats.
e• = — �a1 Waste shall be applied to land eroding less than 5 tons per ace per y emsn
�'v aste may be applied ro land that is eroding at 5 or more tons, but less r=an 10 tons
p er acre per year proV._ -- Vnass filter strm s are insalled wher e runo=',eaves he held
(See FOTG Standard --p_ -Filter Strip).
5- Odors can be reduced by liectine the waste or d- = after waste aroicat;on- Wave
should not be applied when :he, is danger of drift uom the irrigation field
6. W aea animal wave is to be applied on acres subjec to flooding, it w-il1 be ;oil
incorporated on conventionally tilled cropland_ When applied to cone ,,ariontumed
crops or grassland, the wave maybe broadcast provided the application does not
occ-,= during a season prone to flooding. (See "WeatiHer and Climare W Noah
Carolina" for guidance.)
i - Licuid waste shall be applied at rates not to exceed the soil infiltration rare Bach tHat
r-Wou does not occur oz,ie or to surface waters and s a method which does not
cause deft from the se during application- No pond.in.g should occrr in order to
ccnt.rol odor or flies.
$• A-zL al waste shall not be applied to savurated soils, duress rainfall evens, or w$en the
sue:-21ce is frozen. `

REQUIRED SPECIFICATIONS
(continued)
9. Animal waste shall be applied on actively growing crops in such a mast.- that the
crop is not covered with waste to a depth that would •inhibit growth. I-ze poreatialfor
salt damage from animal waste should also be considered.
10. Waste nutrients chil not be applied in fall or winter for spring planted coos on soils
with a high potential for leaching. Waste nutrient loading rates on these sous should
beheld to a mini
mnn and a suitable winter cover crop planted to take tin neared
nutrients. Waste s 2a not be applied more than 30 days prior to plantiag of;he crop
or forages breaking dormancy.
11. Fey new swine faF. nr sited on or after October 1, 1995 shall complvws the
following: The outer perimeter of the land area onto which waste is nnKed from a
lagoon that is a co=oneat of a swine firth snail be at least 50 feet fro' =y residential
propern, boundar;mrdsomany perennials-e=orryer(otherth.­an ea -on
r =ch or canaL 4� waste other than sine wale from facilitiesv ed or -or -
October 1, 1995)2 _01 not be applied closer than 25 _et to perennial v zce-. (gee
Standard 393 - Fitte- St:ms).
12- ?=imal waste shallrot be applied closer than 100 et to wells.
13. a mimal waste shall _ot be applied closer than 200 met of dwellings ogre: moose
owned by the landovzer.
14. Waste shall be appLed l a manner not to reacts ot^ e.- property and pubs: _t-or=
w'ays.
15- Animal waste shallnot be discharged into Surface waters, draiaageways, orwe',laads
by a discharge or by over-saray-iag. Animal waste may be applied to prior converted
w-erlands provided they have been approved as a land application site by a "technical
'? e` lal aast". Animal wale shall not be applied on =ass.:d waterways that Esc arze
dire- 1v into water courses, and on other grassed waterways, ware shall be applied at
a� onomic rates in a manner that causes no runo>i or dritit from the site.
16. Domestic and indus—,:al waste from washdown facilities, showers, totters. is, etc.,
Lail nor be discharged into the animal waste managem_r system-

REQUIRED SPECIFICATIONS
(continued)
13- If animal production at the faclity is to be suspended or te.-mmated, the owaeris
responsible for obtaining and implementing a "closure plan', which wU e!i=;aate the
possbility of an ffie;al discharge, pollution and erosion.
19. Waste handling strucores, piping, pttmps, reels, etc., should be mspecr-d on areaalar
s b as to prevent breakdowns, leaks, and spills. A regular maintenance a
caec
be kept on st-. kfis should
2 0 - Animal waste can be used in a rotation that includes vegetables and oL-- tops for
dse--t human consunzotion. However, if animal waste is used on crops for Cdect
human consunaption it would only be applied preplan with no further appLc_dons of
animal waste during Tae crop season_
21- ably visible naarke., shall be installed to mark the top and bottom eln _er s of the
rein_ orary s orage Cpu=ir= volume) of all waste ti earment lagoons. P—h_ shall
be managed to maiau rae liquid level between the marsers. A Trp s w: F be
required to mars the z'i'imum storage volume for waste storage ponds.
22. -Vast-- shall be t led wi t 69 days of utilization and sons shall be tested at least
ate. nually at crop sites w i e waste products are applied- Nitrogen shz-7be the rate-
dete-miaiaa element 7=c and copper level in he souls shall bemoms-d and
i-
aernative crop sires shall be used whey these mesas approach excess:- le es. pH
nail be adjused for op t== crop production and =a-mrained. Soil andwa_.-
analvsis records shaft be k-pt for five years- Poultry dry waste applica_on r=ords
shaI1 be maintained for three (3) years. Waste application records for ,T other waste
shall be maintained for d-e (5) years_
23- Dead animals will be disposed of in a manner that meets North Carolina recations.

�Z.aSTE UTILIZATION PLAN AGREEMENT
NC-r--e of.
OwnerliVanager Agreement
I (we) understand aad willfollow and implement the sa eci$ration and the apeation and
maintenance procedures established in the approved animal waste utilization plan for the
fans named above. I (we) know that any exPanon to the existing desicm caoachy of the
waste treatment and storage system or construction ofnew facilities WE r-Rare anew
ce-tiucation to be submitted to the Division of Environment Managemeat (D24) before
the new animals are stocked I (we) also understand that there mltst be no e;scaarge of
animal waste from this stem to surface waxers of the state from a stop - Zat less
severe than the 25-year. 24-hm our storm. T'ne approved plan will be Sled o -=e at the
a--= office and at the o=ce of the local Sou and Water Conservation Disc, and WE be
avaEaole for review by DEM upon request.
Name of Facility Owne: W e G
(?lac;a: r:nfJ
D
Name of Managet(Ifaii=ereat from owner):
Si— azLire:
Name of Technical Sper_ast: (P!eare
Address (Agency):
Si=-- --ru:
Date:

V t
. l I'll
c,
V oIJ) R' fryatv
V01P :l� Ir!7'y,
I
UJ
fit'. "S 4 was
4 twin,rt &
. ..... .... ..
01
%`7R z
lfl<!, N �N
zzZ: ✓
iA
;P -A, k"
..... Y:7.),j
, X�0rv,
t4tl- 0 MW
�N
1. .. ....
JAM gy:
.. .. .. ....
A,
"NPQ "A-
y
jW-atl
.bk
v 'F , .
u 'W* ", v.
X♦1
0I am 1
. N�jz%�N
W-5 "p, ju%q -1b
kiwis
............
tog 0:
WOOS"
Q,i"tkNl'
Ig
A,; Cl,
r: "I
Al
I. .
.vT
4W
MlY,

ire-Trac. (L.D�fla. 3 /LApk-NA

r V, �J,l \�� L�✓ �:,+/��o'�r �)(\'�� '� !d�-� VT,. J'�' lJi 1 y, '�,r�+! �Y
MX
tj
• � / 1 � r 1 �'. O ' 7t\' }r � I r V / , � 1) 'r r31�,/ I /),✓ �M� � )i.
N-Ir u �i \ „ r
� �I/ ` ii' 1) � .�� C ':r/ 1✓. 1 � I' ( "`• �yaT {1 1J�1� t I\jf
L
trS�}1 >fi/:'�i•Y�r`\1`'�i (,•' �9ddwy�l'..`�`7 �t�� 'r'+RJ
eA
\ Y c ✓�� 1 7 '� \ it` -r�� 1 , �
+ ji1'\\` / ' ,Y•.' /. .IVVVV. \ �j \>tnt t r• \ � tltl, 15\ ',..✓f '!ti�•3.4,
r _. (f) ± �! ' �! S.//, 1� \ 1 � \ t �.`�( � � r �� e rf•n .•� 117t\ � ����h')(� I _��� A`
ta+ . r✓ ✓'%1, �\ t ��``, f f ! `. • `� ar 4 t1 ` 1` !1 �{�t/ 1 S` f k •�1 n.'
t..'• �
lA1`^ri1 '1
�ll' (~r ✓ � ! � ^\ •y .�•. ` ,` f '.:` \xil �3 �°1''J ij ' ' „ bx � �.,•
r /
r4r1 ". i v..�+ ri J 11 'pill\el it
T/ !' /!j J ,t•\` � F�� y3 C4 ':� l l' ' ':t,--� r•• ` 'S ` �rfT,.� i f�)��Ef,t,� 1 �t ,,),
tifir)
W 1\ ` /f !' I}� Yt r+ '11��� `I ji 71f r,Ir IV `I •,. it , !F S >h 4\ 1
WV
.r ..� \ r J �t / r t1�`♦��� ��4 i 1, },,���f i/ 1 fi'`II` 1 .., I�'�� \ r'tIJF �\ _1J
'';�i"�+y� N t � r� �` It�t r'r 1 2•:.�' i ]/1't .� �J`}' r''� 3 <f1t '.''r �; � r / �' r�
.i �•h Gi•+s',+'� f .I,J r � r Y,1\ �l �'1 /'L C � t �r'J 4 � � ' �• i'(p�� t �, � �" `I
\u •/ \x ✓ r V` ` •// w ilJ y %'r�,t� r'*,.
✓^.4 I YJ �} 1� l� I:f �r� 1�, x � I y'kVJ�'tt• .4,1 ,,,,� r cJ� �-� iS i\ . t\ L!�`!µH5\ 6k
�
\ G'Wy c' (y A.'•✓y4"' + , ( +% .S ii"• d `l�� '\ti'VIa�ll11 /
� i t :
.C' j\ '•n Ilwl l� VI^ {) 31f^�qrr %70� tI tl y�lT ,if4 t'/ 'rti
i s.(' !`t: /. � ' '�`' 'cl'� t'tt .•. i. n;, .�i>;-:� (. ''�i� tly rc���
, 1 1
it yr731 ("i�• ,
ki�J� l

FAFM NAME: Hairy North lagoon DATE: 05r12/96
9 OF ANIMALS DONE BY: WGS
Ci vli.ouco I
NURSERY 400
SOWS 2317
STMkOE 1fOL
TREATMENT =
STORM =
ICMr'Vt'Wti7 =
TOTAL USEABLE VOL =
%OF
REDUIRED
ArTUAI
REOUIRED
DEPTH
1150261
1750261
100.00%
12.34
88226
88226
100.009/6
0.66
36 245
; 246B
19.9o"e/
0.566
1601732
1310975
81.85%
13.%--
DAYS OF TEMPORARY STORAGE:
DEPTH OF SLUDGE
FOR act CAY STORAGE:
3$
1.0
HAVE 0.91 CU FT TREATMENT PER ALW
NU 1 C: 1 HE ACT UAL VVLUMES UIJP'LAT ED OIV t-1 0 SHEC I AFC CALCULATED
USING THE AREAS OF THE CONTOURS CREATED ON ONE FOOT INTERVALS.
THE TOTA I Vn[ I IRAF r'AI r.1 11 ATpn USING DC`A - 131 LY2029

.s
FARM NAME: Hairy South Lagoon DATE: 04/30/96
Or ANi iliki-S DONE BY: WGS
FINISHER
NURSERY
SOWS 1500 "
STORAGE VOL
TREATMENT =
STORM =
TEMPORARY =
TOTAL USEABLE VOL =
%OF
REOUIRED ACTUAL REQUIRED DEPTH
6495W 649500
100.00%
8.35
65791 65791
100.00'/o
0.66
220?i 17 i i 4225
51.92%
7.19
935308 829516
88.69%
1021
DAYS OF TEMPORARY STORAGE: 93
DEPTH OF SLUDGE
1.0
NOTE: THE ACTUAL VOLUMES DISPLAYED ON THIS SHEETARE CALCULATED
USING THE AREAS OFTHE CONTOURS CREATED ON ONE FOOTINTEWALS.
THE TOTAL VOLUME CALCULATED USING DCA = 829953

THIS INSTRUMENT PREPARED BY WESLEY HAIRR, ROUTE 2, BOX 299-E,
WARSAW, NORTH CAROLINA 28398
STATE OF NORTH CAROLINA
COUNTY OF DUPLIN
THIS DEED OF EASEMENT, is made and entered into this the 14th day
of September, 1993, by and between Carroll Jackson and wife, Avice Jacksonk fOf
Duplin County, North Carolina, party of the first part; and Wesley Hairr, citizen dnd
resident of Duplin County, North Carolina, party of the second part.
WITNESSETH:
WHEREAS, party of the first part is the owner of a certain tract of land
located in Faison Township, Duplin County, North Carolina, which is located adjacent
to the farm of the parties of the second part, containing acres, and being described
in a deed recorded in Book Page . of the Duplin County Registry;
AND WHEREAS, parties of the second part are the owners of that certain
tract of land located in Faison Township, Duplin County, North Carolina, containing
acres, described in the records of Duplin A.S.C.S. records as Farm No.
Tract No.
AND WHEREAS, party of the second part desire to be permitted for a
period of 10 years to scatter and otherwise disseminate swine sewage, manure and
effluent over the cropland located on the tract of land of parties of the first part above
described, said sewage, manure and effluent being derived from the swine production
operation upon the real property of the party of the second part above described.
NOW, THEREFORE, said parties of the first part, for and in consideration
of the sum of Ten Dollars to them in hand paid, the receipt of which is hereby
acknowledged, do hereby give, grant and convey unto the said party of the second part
a right and easement to scatter and otherwise disseminate swine sewage, manure and
effluent in an agriculturally sound manner upon the cropland located on the land of the
parties of the first part above described for a period of 10 years; together with a right and
easement of ingress, egress and regress over and upon said tract of land for the purposes

of scattering and otherwise disseminating such swine sewage, manure and effluent for
the same period of time.-:
The party of the second part agrees to disseminate and spray said effluent in
reasonable manner, and in compliance with all applicable state and local regulations, and
to save and hold the parties of the first part harmless from any claims arising out of said
operations brought or maintained by any third parties.
TO HAVE AND TO HOLD said rights and easements to the said party of
the second part and its successors in title; it being agreed that the rights herein granted
shall be appurtenant to the land and facilities now owned by the party of the second part
for the period hereinabove set out.
IN TESTIMONY WHEREOF, the said parties of the first part have hereunto
set their hands and affixed their seals
STATE OF NORTH CAROLINA
COUNTY OF
thedayand year first above written.
(SEAL)
;SEAL)
V
a N tary Public of the
aforesaid co�j and state, do hereby certify that n-
and and wife
' _e%rpersonally appeared before me this da and acknowledged the
due execution of the foregoing instrument for the purposes therein expressed.
Witness my hand and notarial seal, this �D �` day of dz'l 19L-7�
Notary Public
My Commission Expires:

H A i ►� N F A- -r
System Calibration
Information presented in manufacturer's chars are based on average operation
conditions with relatively new equipment. Discharge rates and application rates
change over time . equipment gets older and components wear. In particular,
PUMP wear tends to reduce operating pressure and flow. With continued use,
nozzle wear results in an increase in the nozzle opening which will increase the
discharge rate while decreasing the wetted diameter.
You should be aware that operating the system differently than assumed in the
design will alter the application rate, diameter of coverage, and subsequently the
application, uniformity. For example, operating the system with excessive pressure
results in smaller droplets, greater potential for drift, and accelerates wear of the
sprinkler nozzle. Clogging of nozzles can result in pressure increase. Plugged
intakes or crystallization of mainlines will reduce operating pressure. Operating
below design pressure greatly reduces the coverage diameter and application
uniformity.
For the above reason, you should calibrate your equipment on a regular basis to
ensure proper application rates and uniformity. Calibration at least Once eve y
three years is recommended. Calibration involves collec-ine and measuring f"igW at
S2Vefa1 Igcat:gn$ In the apDIICcTIon area. Any number of containers can be used to
collect floly and determine the application rate. Rain ca Uces work best because
they already have a grad Uated SCale from which to read the application amount
without , �av;nc to per,"orm additional calculations. However, pans, plastic buckets,
jars, or any-;,inc with a uniform opening and cross-section can be used provided
the liquid coilected can be easily transferred to a scaled container for measuring.
For stationar✓ sprinklers, collection containers should be located randomly
throuchou� ine application area at several distances from sprinklers. For traveling
guns, sprinkiers should be located along a transect perpendicular to the direction
Of pull. Set out collection containers 25 feet apart along the transect on both
sides of the can car. You should compute the average application rate for all
nonuniformity of the application. On a windless day, variation between containers
of more than 30 percent is cause for concern. You should contact your irrigation
dealer or technical specialist for assistance.
'Reprinted for Ce. ;:=,ration Training for Operaricns of Anima! Waste lAanagement Systems Manua/

RN
b a a °
o ❑ti ," td o N
n $ 3•�. d N.00 3 v 3 o
I. O bn.'^
Z•r5 $°CHUC50�B , r: r
bli
aC Uqa). r �)
r�rN0W� O.O �' O
tj'yj a) •a °S 8 .r n3 a>
) " na ri o
) N cJ 12
r
a a >
.UU.j09.5.�� •0
O N
.N T A r •0 .�1 't� 10 0 N q J
a) •� � of O •,n U w >, U S
F O 'cri 5 ko r 3 a) ry, 'R7 ni)
0
0
�n
O❑
a.
o3:,r)'a� 18"oF^oo
bN a-d a. S Iyn
onn °nY,oV� - b3 5
$0 9Or Y tj
a r5'l4 J :5cC
1b rAl
0rA [.
2 S514o
)
ty
I T� •O O b
n
N O
O
tol `UC
,� O
>
('• �I-"
, qj P,��
'n N N'}J
Ia O
b r,t
3 �°
agnYa,.�r„
a N . N
.O
.� O�
G $
a) o
n)
rr0
ten'"a>>
° r
A°).0 5 FJJ N
9P(,0
7
U
.r, , .a
• 1y111
'O bi)
O l
rq
>
>.
o ) 0'
o p Lit
zi p. o°.o
bn
Sot �,
.1
0
O a3
" bn
o
0
ImoI...
N
N
O
N
•�
Jy
,yp�
S
o�
�y
?�.
r, Ih
.`�
n >
Or °1
P,
�'�
.r
0
•u o
.n
E:
pCC
°3Tj
Ha
C.
N
0 0
•�
r
H O O
P
I
>a
rNw
l
o
o
)yy(
r7
o
o
qav
po
oo�
an�l�
V
N
C S
.I)
00
O
,U
ry
a) a
a
"
3_ Oit�t).
>)3
e
U 5 0
z°��
s

Lazoon surface —look for:
1. undesirable vegemtive growth
2. floating or lodged debris
embankment —look for:
1 settlement, cracidn-, or "jug" holes
2. side slope stability —slumps or bulges
3wet or damp areas on the back slope
erosion due to Iack of vegetation or as a result of wave action
5. rodent damage
Large- lagoons may be subject to liner damage due to wave action caused by strong
winds. Tnese waves can erode the Iagoon sidewalk, thereby weakening the lagoon dam.
A good stand of vegetation will reduce the potential damage caused by wave action. If
baffles action causes serious damage to a lagoon sidewall, baes in the.lagoon may be
used to reduce the wave impacts.
Any of these features could lead to erosion and weakening of the dam; If your Iagoon has
any of these features, you should call an aDpropriat. expert f a ;-liar with design and
construction of waste lagoons. You may need to provide a temporary fix if there is a threat
of a waste disc.arge. However, a pe.-nta_*tent solution should be reviewed by the
technical -,-pe_ t- Any digging into a lagoon dam with heavy e.^uDment is a serious
undez—zas-ng wiCh potentially Serious consequences and should not be conducted uniess
r=ommencec by an appropriate to-hni:z exDe.
7ran. sfer Pumps --check for _Dr0_De. Operation Of:
I recycling pL'rnDs
2. i_*tiga�on pLmps
Check for lmaki' loose. n=zs. and overall DUmD or--.- ion. An Unusually loud or "-mding
nOke, Or a image amount of vik—adon, ii.ay inclicat✓ that the DL`a:ip is in need or rwa= or
reDIacemw_ _
NOT`.: Pin ping systems should be inspected and operated frequently enough so that you
are not cornpiewly "surprised" by equipment failure. You should perorrn your-putimm-
system maintenance. at a time when your lagoon is at its Iow level. This will allow some
safety time should maior repairs be required. Having a nearly fuii lagoon is not.the time
to think about swit^hmg, repairing , or borrowing pumps. Probably, if your Iagoou is full,
your neighbor's lagoon is full also. You should consider maintaining an inventory of spare
parts or pumps.
Surza�M, water diversion features are designed to ray all surface
drainage waters (such as rainfall runoff, roof drainage, gutter outlets,
and parking lot runofr) away from your lagoon and other waste
treatment or storage structures. The only wars that should be
corning from your lagoon is that which comes from your flushing
(washing) system pipes and the rainfall that hits the lagoon directly.
You should inspect your diversion system for the following:
1. adequate vegemtion
2 diversion capacity
3. ridge bee berm height

9 N 3,
8�H" lln
9b o.�
pT v
G
UE.9'4
y' 'IEp). ::, o 0 bq ° v
>.
y �N O a p
a3sa�4'� 31
Wp
�'� t �1'S•3" . �•5
o
9�;�� o�Yo
�
o
d >,>
>41
Rip b G
a g $ _p 3
bN
0,'o
TJ vj iE "D ::I bn•g0 p�" o bran .o
•d v 3 � :o P
N> 7 v 0
4�P;�cy
� ChO0
pp�P, >� -Bo l�Vj
> g o
4 �7]'
• o
.o °''i�•L{7I b• pc1 9 41 C, ' uJ
.O ; J o O •�) 5) •N bil o o .P S �. q y
o. b 43
u
cJgo s U«ti3'��>o
N o p"��'
.�I N :.,
.., p .� • c22 IJ � u
N Nni y'o$ N o
.CN p N L.�j C 3 NQ P,q '� ci•arl,
:a 'J ; .00 8 1 / D ,., ` q I y cV r �Py,
p 0 N .� �I� r p qp ESQ o a 7f J •4) •j >!qy .4 .`. b0 ^�y 11 Oa� .:7� •v q
ot,00 o o
p bn o
bn '�
v a bn C bn,y P
j o py :� $ IJ '9 .d 4) ° �.-1 o h o
.-, ,({yamy ,. � A G' t
hll i9 43
[)'
p[ .obn ' ,p O e� ^C,�'t"
•P:0 — I� j [+ o y 1 th pp ♦' ri
o
[ .0 �•:•1.b.v 1' ,oy a .�'c
ra G7i "���77111 •:S �' � o' o 7 y�o
u 3 �1 atij :9 0 3;01` A n,
tf Iri �
t�

�. °) o ° �o
pa f y S} q 5ipp7s
G '3 .-. N 8 .Cj '^ O U U Otp
Ei
ro 0'-� 94
3 a °S91
5bb
�?p 4$
44
•M.([tlOdj ?7 D��y',❑� ''f� O O i �. C�1 ,�y ;
Qrf .0 .� i7 4: •O �j' a) '3 >`'.-'` O �° N •ppr
,y, U : o p a P, 6b
ic
° v a� eu - a, DC d
ai ai RE E•T � r � N 0 U � 0 � `P
3 v° V Sip } oy �O cn P yDt
a J p ai o �v :�v °� ei �' nQf'o r g .p
3 bA r d 0e1 41
•k U °cam; �� F. o II' ICJ n r� °3 y°G'' •- 6n pr! .3�� Nrc'`otP). yyU7' rh P.94 5-P,>, . SS� c°
.rjvN� 9.• j in, vlan14>i
fqy] !aO3

uJ U t• � t• {'ot °) `3 tt t� ai'�o i� t o o b'"p 'U S
>' n,:n J ti I� °J QJ u bf ei o a t3 �. ii •a r� ro c
Py n.
' 4S �4d a .bit ^r.. �� i� Ir lr t!���� N.
n3 •� b, 'ClyS, •a .c 0 d
3 •1+ >. bn 1' >, 7 CS ly r) N i1 C N 3 P'�
aqj
; ❑ E 1-.:u'V « q bno «t' > a)
O r � r. ° 3 $ Cj R S •� ra f [ 5 ii : ! ai nj r
.13
Icoibonsln L .V'vJ ,�{.J , 'tdJ� baln .q-) ), ('�.'•l'� .,r4y'I Laf
14 14b vI1'$ati• ,7l., °rP,
aW
40 .O A).O IJ 9;-j
o 0o a fa)
N PU '� _N
oC:Jw°'.°bb"bn' >°C t0rtJ;
ca av)� a) aU Nb.-•aJ°iai °; >
' a) .o bao ,[b1. 03' Ur�3 10�. ro •�d
a bo ry' to, r�1jf' �� 14 a) p wobiI nAO'a7
N>l soE)t'3G'
>, 0 J)u
P' i oC
OOO O bl a)
U P.'7 N y�� t.. �.o `v��•ty 41 n—�i a)
ttbo. ^t b1O� ) 'p3bb4•1..,l (of O>b $a �P.d0Ear o'
o $ p�O tyNbn
.0 an, I.A. of °)
bn O a) O
.pO{;
.[bO
a) t? r_ !, 0 0.0
j : p Nto.
o Ao d.o:�•a<:n
J 8 ) ° °1 5 n' S u3 .o $ 'a. 3 47 Jr n o d , E a) r u °o F.
u ar 9 0 ai 'i'di b) 9 0 a, w bf J 6:� r� :d v a bn.0 a
a > > ai ) n. i ot�'' d al li a) bn� a t o 5 > o u
N i(' o > F •u 3 :t tub 1.. >• �i aJ 'u ' o G °J a) •S .� >. 5 u c
:9 C o, u a) ( u a) i. J 9 r , u r 1'� a)' o
en �.c ji n, n,o <J n'° IJ.q o aa)) I'� r. PT
'S i� o >
SO d)
tvb
'" aaaWiii a NA �(y r�tt l� {t[dyj Ic�f �p a) 1tNy�
.a N aJ (0 al N I � W U

i
'§ 0I
v 1 � aI n
1� .
j°N g�
O td
6p
Pp.1 CI q ,yf 4I ra
O � o`. aa b0 O l7 7 '� 1 i
8 q
aI I. �q'p, 3
A o� .0 spy bA �' •s s �7a bbo
�.ODt� qb bA •r bA �O 1"'u o ai
bl v
pp 0 + In 'pt •a'114
bn "`FFFccciii �
fi a
,.j
41
Zoo

EMERGENCY ACTION PLAN
PHONE NUMBERS
DIVISION EMERGENCY MANAG MN S SERVICES (EMS)
SOIL AND WATER CONSERVATION DISTRICT (SWCD) 10
d9 -
NATURAL RESOURCES CONSERVATION SERVICE (NRCS) 0 9(, loe
COOPERATIVE. EXTERSION ScRVICE (CES) C4/6.�if, -Jlap
(yt2�a96 -ary 3
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing or running off sire. You should not wait until wastes reach surace waters
or leave you property to consider that you have a problem. You should make every
efforr to ensure that this does not happen. This plan should be posted in an accessible
location for all- employees at the facility. The following are some action items you should
take.
1. Stop the release of wastes. Depending on the situation, this may ore may nor be
possible. Suggested responses to some possible problems are listed belwo.
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. fumD wastes t0 Tie!ds at an acceptable rate.
C. STDD all fIOWs i0 uie lagoon immediately.
d. Cali a pumping contractor.
e. Make sure n0 sl!,"ace water- is entering lc'coon.
a• Runo ;from waste application field -actions include:
a. Immediately stop waste application.
n. Create a TemDorarV diversion to contain was-,e.
c. Incorporate waste to reduce runoff.
e. _:clUcie and ellminate the reasons) that cause the runoff?.
e. _valuate the aop!!cation rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinklers -icon include: .
a. Stop recycle pumo.
b. Stop irrigation pump
c. Close valves to eliminate further discharee.
d. Repair all leaks prior to restating pumps.
D. Leakage from flush systems, houses, solid separators -action include:
a. Stop recycle pump.
b. StOD irrigation pump.
c. Make sure siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
E. Leakage from base or sidewali of lagoon. Often this is seepage as opposed
to T!ovving leaks -possible action:
a. D!c a Small sump or ditch from the embankmenrto catch all
seepage, puT in a submersible pump, and pump back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill
holes and compact with a clay type soil.
C. Have a «m professional evaluate the condition of the side walls and lagoon booas soon as possible.
I'

2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any sur,"ace waters?
b• Approximately how much was released and for what duration?
c. Any damage notes, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach sur-mce waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off the propery)?
h. How much reached surface waters?
3. Cort«cr appropriate agencies.
a. During normal business hours call your DWC regional office; Phone --. After
hours, emergency number: -019-733-3942-. Your phone call should include: your
name, facility number, telephone number, the details of the incident from item 2
above, the exact location of the facility, the location or direction of movement of
the spill, weather and wind conditions. The corrective measures that -have been
under taken, and the seriousness of the sitution.
b. If spiii leaves property or enters surface waters, call local SMS phone number.
C.- Insruct Ey1S to contac local Helath Department.
d. Contact CEs, phone number - , local SWCD 0 ffice phone number - -, and local
NrCS CffiCa tOr advice/tachniCal assistance phone number - -.
4. If „one of the above works call 9 1 1 or the Sheriff's Depa,, Lment and explain you
Problem -Lc ti,em andaskthe person to contact the proper agencies fof you.
5• Conzact the contractor o` your choice to begin repair or problem to minimize site damaca.
0
7.
a. Cor:Tactors Name:
b. Contractors Address
c. Cgn Iaacmrs Phone:
Cor,„ac- the technical specialist who certified the lagoon (NRCS, Consult nc
Engineer, etc.) -
a. Name:
b. Phone:
Implement procedures as -advised by DWO_ and technical assistance agencies to
rect;fy the damage, repair the system, and reassess the waste manaomem plan to
keep problems with release of wastes from happening again.
2

u
£
)
k
|
J
[
k
<
�
/
}
!
\
!
}
3;
�
2z{
!k
!
§■EaE
2;
§}§11
f§
~
[f
[7
/{
§
2
k
)
|
7a
$
!,.
:§®10
}7§|§)7
°!l0
\\}}}\\

«
}
EL
[
ƒ!}
E
©
k
}}}`
.|`■
!7
;
tml
!
�E
t
/
)§�i
�})77/7
{
!7�}.00
|
/
|
�
m
'
]
�
a]!
k
0
§
)
`
Cc
<
\|
U
'.
22
|
#
|
}|
.2 7
§
to
!
W
&{
/ f
—
k
§
§

}/(
�
]
\}Ji
|
t
tj
7
§
{°la}
'0
_0`
§r
{(}7
§
�)°En
0
"i i
/|
s
)
£
k
r
,
;
)
)
�
!
E
"
rl
a
z
!a
z
■
!
�
>
"
\
k
\
k
) k
`
0 c
k
E
/
f
-
m
f!
{
\
}
®�
;\}
!�R{�
|§§
rm
-
«kg
§!{!:
IL,
\§;•.3
\
.;;�{)�
{\!}
1,.
;[)E
!!!4
,
#

Storage tank or Resin
surface
Set -ling basin surface
Manure. slurry or yutaga
spreader oud,=
Uncovered manure. slurry
or sludge on field surfaces
Dead animals
Oead animal disoosal
.=.its
Incinerators
xandrng waur arocr.0
'acii)ties
Partial microbial dacempesition
Miring while firing
Agitation when emptying
Parties micobial decomposition
Mixing wlaie filling
Agitation when amprying
Aptsoon when spreading
Volagla gas emissions
() Sodom or midlevel loading
OTank covers
() again surface mats of solids
O Proven bialogioel additives or oxidants
(1 Extend drainpipe otrttets underneath liquid
level
() Ramove seiti d sciids +eCulady
() Soil injection of slurry/sludges
(I Wash residual mom,. from spreader after use
() Proven biological additives or oxidants
Volatile gas emissions while drying () Soil infection of slu rry/sludpas
() Soil incorporation within 48 hours
() Spread in thin uniform layers for rapid drying
() Proven biological edgftd s or etddants
Canvass decomposition
Caress decomposition
Incxrpiete combustion
Lrropar drainage
M lcmbial decomposition of
o antic matter
Manure tracked once pubiie Pcony maintained access roads
roads from farm ar_ess
dditional Information:
() Proper disposition of -
Comp Ote covering of carcasses in burW pits
() Proper IoeavoNeanrzugdon of disposal pia
() Socortdary static burners
urxe and landscape Sven that water drains
away from faalities
access road maintenance
wine Manure Menagemerrt C'OO nularMP Packat
;wine Production Far Potential Cdor Sources and Remedies, FBAE Fact Sheet
a wine Production Fachiry Manure Management Recnerge-lagppn ;
i wine Production Facility Manure Management a Treat. -train, SAE 2a_g8 Underfioar Ruse -lagoon Treatmen- E3,:,E )?s-da
.spoon Desig and Management for;ivestock Manure Treatment and Storage-. FBAE 1 O3-c^a
:alibration of Manure and Wastewater Application c-;t, ltalha • c3gE Fact Sheet
ontralling Odors from Swine &aiSrngsc PIH-33
.ivironmental Assuranc Program_ NPPC Manual
otions for Managing Odor, a reaor, fmm the Swine Odor Task Fore.
jisanee Concems in Arirnel Marque Management Odors and Fries; PRO107. 199S Conference Proceedings
AvSiadie FT—•
NCS'.r-:urry Ex;artsion Center
N'4S —AE
NG(;.=-AE
NSU- A-
NS'. --
NSIJ-BAE
NSu'Swine E;Csatmon
NC Pont Produces Assoc
NSU Agri Communi and,=
Ronda Coopsrsdve Extwt i n
-ie issues checked ( ) pertain to this operation. The landowner�ntegrator agrees to use sound judgment in applying
nor control measures as practical.
:ertify the aforemerrcioned odor control Best Managment Pracices have been reviewed with me.
GFCancowner Signature)
7C-November 11. 1995

- MOR7-gL17Y
(check which me�od '4GEME1u7' 1�]�-HODS
(s) are being imp/ernented)
� ) Burial three fee
anye oknowledgeofnOath the
w'ng rh rh
eam rhpublicurface
deatbo Or the round -
bur'al egar/east Soon 24 hours Rendering at a refeet from
ndering plane licensed
( ) COMP/ere incineration under G. S. 106- 168. ,
desrhe case of dead
9n Poet
approved by the pe only, P worn
An Partme. ,. Agr a disposal Pit of
Anyr "hOd which in t ture, c size and
animal's value would Make Professional
aPProval of the Sth� -Z Qdassi ie the
husaprage nion07 the State
nnarian Par o f a dead
mus mbe tte h,d) health. (Written en

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
Wesley Hairr
Hain I Sow Farm
1188 Veach's Mill Rd
Warsaw NC 28398
Dear Wesley Hairr:
RECEIVED
WK, ^<CtUF Ii"SP(MON
JUN a 1998
Non -Discharge Fer..
l a
D E N R
April 29, 1998
Subject: Application No. 31-0200
Additional Information Request
Hain I Sow Farm
Animal Waste Operation
Duplin County
The Non -Discharge Permitting Unit has completed a preliminary engineering review of the
subject application. Additional information is required before we can continue our review. Please
address the following by May 29, 1998:
You have indicated on your permit application that your facility began operation in 1993. In
order to complete the various components of the certified animal waste management plan, please submit
two copies each of the following documents that may be applicable to your farm:
1. NRCS Site Evaluation Form (NC-CPA-17)
3. Wetland Determination
4. A credit for residual nitrogen from a leguminous crop such as soybean in a crop rotation
must be accounted for in the subsequent crop. Hence, nitrogen application rates to the crop
following a legume should be reduced by 15-30 lb. per acre depending upon the soil type.
Please revise your WUP to properly list all application rates with residual nitrogen
incorporated into your cropping scheme.
Please consult your technical specialist for further assistance in determining and obtaining
documents required for your farm. Please include an explanation if any of the above requirements do not
apply to your farm.
Please reference the subject permit application number when providing the requested
information. All information should be signed, sealed, and submitted in duplicate to my attention at the
address below. The information requested by this letter, must be submitted on or before May 29, 1998 or
the Division will return your application as incomplete in accordance with 15A N.C.A.C. 2H .0200 and
your facility will be considered to be operating without a permit.
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Application No. 31-0200
Wesley Hairr
Page 2
P lveD,o�
VJAi
JUN d m9
Please be advised that operation of the subject animal waste inanagemeiit system without a valid
permit is a violation of North Carolina General Statute 143-215.1 and will subject you to the enforcement
authority of the Environmental Management Commission.
If you have any questions regarding this request, please call me at [phone], extension 363.
Sincerely,
J R Joshi
Soil Scientist
Non -Discharge Permitting Unit
cc: Wilmington Regional Office, Water Quality
Permit File

05/14/98 THU 09:52 FAX [phone] MITCHELL & ASSOC. RECEIVED 0002
WATER 01J: ' iTu ^'I'TIQN
DATA FORM JUN A N4A
ROUTINE WETLAND ousmimnoN
111997 COE Wetlands Delineation Manual) Non-Dismnarge Permitting
VEGETATION .
i" V. •loll -. 1asL a p•
J
..mill
Pomem of Dominam Speciae that am OBI. FACW or FAC
Rarnarksi
HYDROLOGY
_ Recorded Date (Damerlhe In Remarks);
_Stream, Laks, or TWO Gaup$
Amid MwtcVsphs r
_Other:•'
Reoaridd Date Available
Fdd Ohsemsomt
Depth of Surface Water. 'J Gn.l
Depth to Free Water In lit n.l
Depth to sowratsd Salt �., fin.)
Remarks:
Daminant Plant SI!22!N etranr Indicator
a.QSMukjfl} Ox1 N" d F F .�
10.�AiLTAIUYYr 5��. � ii �
11.
lz
13.
14.
is.
Wetland HydickW hdiaatom:
Primary I diestare:
Imodatod
�Fremd in Upper 12 Inches
_ Water marks
�silrfJnes
sadbnem Dap*$"
1 Rape Potters in Wetlands
Secondary hrdlemm (2 or more required!:
gip: idixed Root Channels in Upper 12 Inches
:,W�o-Staitad Leaves
_ Local Soil Survey Data
FAC-Nsutrel Test
Other (Ewplain in Remarks)

05/14i98 THU 09:52 FAX [phone] XITCHEU & ASSOC. Q 003
FIftjwl
map um-t NNY ' • • �• (
tSariea and Phasal: K-N'I NS
..
Drainage dMc — ?COP —
: •. i
Taannorrty fSuEgiwir)e'`:':r" -' ` LC� '
Field ob"mUctia
E.! - . COMM Mapped Type? Yea No
Dapth......... .... :..:•:lAp1>biCotnr .'..
Mattis Colon Mattis . Tsxture, Concretions,
fin^-�here/�}� .. enQ.en IMUMen Meted
LMone.n_Molad �lhundenceiCantrest tmctuto. a
g-.^
Hyeric Sail Indlaaton:
'
it
.. •-' .. i �
_wsmad
II
anOrallarm
_ wade E"odon
wgh CMirdo Content InrSurfaee Layer In zany Sall*
�I `WNW Odor
Oroanlo 9traaWng In Sandy Soils '
_ A41WO Mobatfe Regina,
listed on Local Hyddo Sogs Dst
Radgcing Canadom
`Ustad On National HV Wo Solis Let
`Cloyed or Lots -Chrome Colors
i
`Otnar IFxpWn in Ramerks)
itRtmarka:
..
WETLAND DIFTE WINAT10N
Hydraphyda Vegetation Prasant? - Na tarcla) (Circic)
wadand Hydrology Prasont? : _ Nor
Myddc Soils Present? yes No Is We Sarcpling Point Wltun a Wedsnd? Yon No
Romano: .

05i14i98 THU 09:53 FAX [phone] MITCHEU & ASSOC..
1� 004
DATA FORM
ROUTINE WETLAND DETERMINATION
(1987 COE Wetlands Dellmadon Manual)
VEGETATION
ammara A Soso"
�,
t.)�In1C4S9r:
nel
j_e+1t
aM Re [ 8 e �[[=[n--
1��(cm
rQ I�'I/�I�7i3
�w�r
GS dLY
S. �j"S�)Q
!J �P.� `r am
��
11 hY . L,;A J L.
,� �� ix=hurt An' JAWnI r-
��.r
s 3:t
t`�I
4.A1—Y rlbralnn Z_ *
a.r✓ 5�
r i
Percent of D01nlrrent 80e016$ that are 08L. FACW or FAO
(excluding FAC•).
Remake:
_ Repented Data (Desed1w In RamerlW:
Stream, Wte, or Tide Gauge
—.As.PhotaSrwti
_VHe Rsawdsd Dear AvaBile .
Sold Observations:
Depth of Surface Water. pn.)
Depth to Free Water in Ok: ! �' on.)
Depth to Saunned Sell: OnJ
Wadand HvdtokW Mdiostars:
Printery Ind)est=
Invittlated
=mEs Ssamita.
d M upper , z Inches
Water Marks
Or n lines
SedarwM Deposits .
Drainage Patterns in Wadands
Sec ary Masters 12 or more nau)rad):
Oxidized Root 0ta nnals In upper 12 Inches
Water -Stained Lomas
Local Said Survey Data
FAC-Neutral Test
Other (Explain In Remarks)

05/14/98 THU 09:53 FAX [phone] MITCHELL & ASSOC. 9 005
SOILS
. o At Nime
.
t5eries and Phosel.— _ �Ic.T7 ��.
Drainage C(aaa:
. • ... a:..
Takotwmy �ubtiroit7l::..'.: I -
Reid Obarvadam
i.� ' :. Confirm Mapped Tvpa? Yea No
Pro file Daaa+ietionr- '
.'�/tfbC ♦�.alOf".
Oeptir ....—^• — •^ '.
Mattis Cdors Mottle . Tax Wrar.Ca(IOratiOM.
fncheel .. _ Horizon (Muntall MeleN
(Wmaell Male:l Stnictu_ ra, etc.
ion)
�i
Mydric Sol tndlwton:'
q
Hlawed
rtcredora
— Watie Epipd..
`High Ctgado Content In Sudace Lavar In Sandy 5ails
—Sulfldlo Odor
—Organic Svaaking In Sandy Sails
,_,.,A9u14 Moistwe Raglme
�Ustad on Local HydNa Solis List
— Reducing candldons
_ Ustad on National HYdric Sala Ust ;
— Giayed or Luvr•Chroma Colors
A
—Other IExplsin In Remarks)
AemariC4:
I
II
•.
WETLAND DETERMINATION
Hvcrophytia Vegetation Preeent? Y (Clrcla) IClr -
Wetland Hydrology Prasent7 n
hydric Scls Presant? Yes I. this S"Piing Paint Within a Worland? yeas
Remarks:

Producer: WC611-y no,�rr (-�
Location: 117T Jeoct.'s nn:ll Rd.
I..es.,a)n/G a1099
Telephone: oko)a13-303(
Type Operation: Feeder-%`.I5
Number of Animals: 35o c),� o� s
(Design Capacity) 100 O Y'n4t%In
No nNf3 P�
The waste from your animal facility must a land applied at a specified rate to prevent
pollution of surface and/or groundwater. The plant nutrients in the animal waste should
be used to reduce the amount of commercial fertilizer required for the crops in the fields
where the waste is to be applied. This waste utilization plan uses nitrogen as the limiting
nutrient. Waste should be analyzed before each application cycle. Annual soil tests are
strongly encouraged so that all plant nutrients can be balanced for realistic yields of the
crop to be grown.
Several factors are important in implementing your waste utilization plan in orderto
maximize the fertilizer value of the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply more nitrogen than the crop
can utilize. Soil types are important as they have different infiltration rates, leaching
potentials, cation exchange capacities, and available water holding capacities. Normally
waste shall not be applied to land eroding at greater than 5 tons per acre per year. With
special precautions, waste may be applied to land eroding at up to 10 tons per acre per
year. Do not apply waste on saturated soils, when it is raining, or when the surface is
frozen. Either of these conditions may result in runoff to surface waters which is not
allowed under DEM regulations. Wind conditions should also be considered to avoid drift
and downwind odor problems. To rnwdmie the value of nutrients for crop production
and to reduce the potential for pollution, the waste should be applied to a growing crop or
applied to bare ground not more than 30 days prior to planting. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. Acreage requirements should be based on the waste analysis
report from your waste management facility. Attached you will find information on
proper sampling techniques, preparation, and transfer of waste samples to the lab for
analysis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A
NCAC 2H.0217 adopted by the Environmental Management Commission.

y
o
3
e%
�-
vr`
c
O�j
IN
jMJ_
..
0 a
U
rl
00004
� U•
}
_
a
9� VI
w e
O d
H
o
000
vor
0 v
9,00I
7
Iri
a
0
U
ml
to
w
u
fN
rl

z
4
G
r
I
Fa
D'
U
u
-1
7��
�N
1
G

rj
O
6
11,

See attached map showing the fields to be used far the utilization of waste water.
Application of Waste by Irrigation
Field Soil Type Crop Application Application
No. Rate (Tn/FTr) dmm. +tT..
li a 13I
AA
R.. c.e S
iLf
A16 ki
owC,v
,5
.5—.0
tisb-I
IO 15 lb
L
5-
THIS TABLE- IS NOT NEEDED IF WASTE IS Nor BEING APPLIED BY IRRIGATION, HOWEVERA SBELARTABLE WILL
BE : DED FOR DRY ISr1IIt OR SLURRY
Your facility is dessined for�Ldays of temporary storage and the temporary storage
must be removed on the average of once every _MONTHS. In no instance should
the volume of waste being stored in your structure exceed Elevation A to a�
Call the local Natural Resources Conservation Service (formerly Soil Conservation
Service) or Soil and Water Conservation District office after you receive the waste
analysis report for assistance in determining the amount per acre to apply and the proper
application rate prior to applying the waste.
4

REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff drift, manmade
conveyances, direct application, or direct discharge during operation or land
application. Any discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the producer either owns or has
an agreement for use of adequate land on which to properly apply the waste. Ifthe
producer does not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a reasonable
proximity, allowing him/her the use of the land for waste application. It is the
responsibility of the owner of the facility to secure an update of the Waste Utilization
Plan when there is a change in the operation, increase in the number of animals
method of utilization, or available land.
Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic
crop yields based on soil type, available moisture, historical data, climatic conditions,
and level of management unless there are regulations that restrict the rate of
application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre per year.
Waste may be applied to land that is eroding at 5 or more tons, but less than 10 tons
per acre per year providing grass filter strips are installed where runoff leaves the field.
(See FOTG Standard 393 - Filter Strip).
5. Odors can be reduced by injecting the waste or disldna after waste application Waste
should not be applied when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil
incorporated on conventionally tilled cropland. When applied to conservation tilled
crops or grassland, the waste maybe broadcast provided the application does not
occur during a season prone to flooding. (See "Weather and Climate in North
Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
runoff does not occur offsite or to surface waters and in a method which does not
cause drift from the site during application. No pondmg should occur in order to
control odor or flies.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.

REQUIRED SPECIFICATIONS
(continued)
9. Animal waste shall be applied on actively growing crops in such a manner that the
crop is not covered with waste to a depth that would inhibit growth. The potential for
salt damage from animal waste should also be considered.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste nutrient loading rates on these soils should
be held to a minimum and a suitable winter cover crop planted to take up released
nutrients. Waste shall not be applied more than 30 days prior to planting of the crop
or forages breaking dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the
following: The outer perimeter of the land area onto which waste is applied from a
lagoon that is a component of a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other than an irrigation
ditch or canal. Animal waste other than swine waste from facilities sited on or a$er
October 1, 1995), shall not be applied closer than 25 feet to perennial waters. (See
Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and public right-of-
ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands
by a discharge or by over -spraying. Animal waste may be applied to prior converted
wetlands provided they have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc.,
shall not be discharged into the animal waste management system

REQUIRED SPECIFICATIONS
(continued)
18. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks, and spills. A regular maintenance checklist should
be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops for
direct human consumption. However, if animal waste is used on crops for direct
human consumption it should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and bottom elevations ofthe
temporary storage (pumping volume) of all waste treatment lagoons. Pomping shall
be managed to maintain the liquid level between the markers. A marker will be
required to mark the maximum storage volume for waste storage ponds.
22. Waste shall be tested within 69 days of utilization and soil shall be tested at least
annually at crop sites where waste products are applied. Nitrogen shall be the rate -
determining element. Zmc and copper levels in the soils shall be monitored and
alternative crop sites shall be used when these metals approach excessive levels. pH
shall be adjusted for optiimim crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry waste application records
shall be maintained for three (3) years. Waste application records for all other waste
shall be maintained for five (5) years.
23. Dead animals willbe disposed of in a manner that meets North Carolina regulations.

WASTE I TII,IZATION PLAN AGREEMENT
Name of Farm NaiK/T }ZQrr-,
Owner/Manager Agreement
I (we) understand and will follow and implement the specification and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. I (we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction ofnew facilities will require anew
certification to be submitted to the Division of Environment Management (DEM) before
the new animals are stocked I (we) also understand that there Trurst be no discharge of
animal waste from this system to surface wasters of the state from a storm event less
severe than the 25-year, 24-hour storm. The approved plan will be filed on -site at the
farm office and at the office of the local Sort and Water Conservation District and will be
available for review by DEM upon request.
Name of FacilityOwner. W e l e. ^I a cv�-
(Please print)
, t
Signature: ! A Date: I u /I I9 -7
Name ofManager(Udifferentfrom owner):
Signature:
Date:
Name of Technical Specialist: (Please print) • ra
Affdiation:A ,wrOL-4 FZ .A-1 rCX t-V. �s
Address (Agency):
6
Signature:
tj///77
6/31n

)FGf 5 a-F fLirr Trcc-4-C�2e.+IanA /url4nq

IV 1 14-, . VJ 3
, CV*V�.Y �7,
zQ
RAT
"NN

C' �J
Operator:MURPHY FARMS, INC.County: DUPLIN Date: 01/22/93
Distance to nearest residence (other than owner): 1000.0 feet
1. STEADY STATE LIVE WEIGHT
0
sows
(farrow to finish)
x
1417
lbs.
= 0
lbs
0
sows
(farrow to feeder)
x
522
lbs.
= 0
lbs
0
head
(finishing only)
x
135
lbs.
= 0
lbs
1350
sows
(farrow to wean)
x
433
lbs.
= 584550
lbs
0
head
(wean to feeder)
x
30
lbs.
= 0
lbs
TOTAL STEADY STATE LIVE WEIGHT (SSLW) = 584550 lbs
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
3.
4.
Volume = 584550 lbs. SSLW x Treatment Volume(CF)/lb. SSLW
Treatment Volume(CF)/lb. SSLW= 1 CF/lb. SSLW
Volume = 584550 cubic feet
STORAGE VOLUME FOR SLUDGE ACCUMULATIOS/� Q ��'od �aaJe ina� fe}w�t
G r
Volume = 0.0 cubic feet
5�4�� 6QiJV od +1lta�e�
TOTAL DESIGN VOLUME 111
Inside top length 310.0 feet Inside top width 346.0 feet
Top of dike at elevation 51.2 feet
Freeboard 1.0 feet ; Side slopes 3.0 : 1 (Inside lagoon)
Total design lagoon liquid level at elevation 50.2 feet
Bottom of lagoon elevation 40.1 feet
Seasonal high water table elevation 44.3 feet
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH
3.0 3.0 3.0 3.0 304.0 340.0 10.1
AREA OF TOP
LENGTH * WIDTH =
304.0 340.0 103360.0 (AREA OF TOP)
AREA OF BOTTOM
.LENGTH * WIDTH =
243.4 279.4 68006.0 (AREA OF BOTTOM)
AREA OF MIDSECTION
LENGTH * WIDTH * 4
273.7 309.7 339059.6 (AREA OF MIDSECTION * 4)
CU. FT. _ [AREA TOP + (4*AREA MIDSECTION) + AREA BOTTOM] * DEPTH/6
103360.0 339059.6 68006.0 1.7
VOLUME OF LAGOON AT TOTAL DESIGN LIQUID LEVEL = 859216 CU. FT.

. 5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
310.0 346.0 107260.0 square feet
Buildings (roof and lot water)
Length * Width =
0.0 0.0 0.0 square feet
TOTAL DA 107260.0 square feet
Design temporary storage period to be 180 days.
5A. Volume of waste produced `
Approximate daily production of manure in CF/LB SSLW 0.00136
Volume = 584550 Lbs. SSLW * CF of Waste/Lb./Day * 180 days
Volume = 142751 cubic feet
5B. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush -systems that recirculate
the lagoon water are accounted for in 5A.
Volume = 0.0 gallons/day * 180 days storage/7.48 gallons
Volume = 0.0 cubic feet per CF
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by.largest amount.
180 days excess rainfall =
Volume = 7.0 in * DA / 12 inches per foot
Volume = 62568.3 cubic feet
7.0 inches

5D. Volume of 25 year - 24 hour storm
Volume = 7.5 inches / 12 inches per foot * DA
Volume = 67037.5 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A.
142751
cubic
feet
5B.
0
cubic
feet
5C.
62568
cubic
feet
5D.
67038
cubic
feet
TOTAL 272356 cubic feet
6. SUMMARY
Total required volume 856906 cubic feet
Total design volume avail. 859216 cubic feet
Min. req. treatment volume plus sludge accumulation` 584550 cubic fe
At elev. 47.4feet ; Volume is 584692 cubic feet (end pumping)
Total design volume less 25yr-24hr storm is 792179 cubic feet
At elev. 49.5 feet ; Volume is 787807 cubic feet (start pumping)
Seasonal high water table elevation 44.3 feet
7. DESIGNED. BY: APPROVED BY: /
DATE: DATE: 3
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN

FEE Hi 193I 11:1�,
P.7
OPERATION AND MAINTENANCE PLAN
Thin lagoon is designed for waste treatment with minimum odor
control. The time required for the planned fluid level to be
reached may vary due to soil conditions,flushing operations, and
the amount of fresh water added to the system.
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent runoff from the field or damage
to crops.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre -
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see Attachment B)
before land application.
3. Begin pump -out of the lagoon when fluid level reaches eleva-
tion 49.5 as marked by.'permanent markers. Stop pump -out when
the fluid ievel'reaches elevation 47.4 or before fluid depth is
less than 6 feet deep (this prevents the loss of favorable
bacteria) .
4. The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended maximum application rate is e.4
inch per hour.
5. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
outlets.
8. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Environment. Health, and Hetural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.

Pit
Hairr 3400 Sowform Duplin County .
Lagoon #1
Typical View of a One —Stage Lagoon System
High End Pad Elevation
Low End Pad Elevatio
Confinement
Building
12
57.8'
51.5'
Top width:__1 2:,
Settled Top Elevation:__ 51.2'
Pi PQ T nVeri' 149.5
Fluid Elevation: 50.2' _
Treatment Lagoon
pipe (Needs to be
adequately supported) Depth:
Bottom Elevation:-40.1
Inside Side Slopes:`3:1
Outside Side Slopes:_3.1 __ .
J INVCSi4' Leh
SLcc4J. V

mm"s Amon
1�Z�7 wl�lil11.1�4[�J��
AREA TO BE SEEDED: 13.0 ACRES
USE THE SEED MIXTURE INDICATED:
0 LBS. FESCUE GRASS @ 60 LBS./ACRE
(BEST SUITED ON CLAYEY OR WET SOIL CONDITIONS)
SEEDING DATES: SEPTEMBER 15 TO NOVEMBER 30
0 LBS. 'PENSACOLA' BAHIA GRASS @ 60 LBS./ACRE
(SEE FOOTNOTE NO. 1)
SEEDING DATES: MARCH 15 TO JUNE 30
104 LBS. HULLED BERMUDA GRASS @ 8 LBS./AC.
(SUITED FOR MOST SOIL CONDITIONS)
SEEDING DATES: APRIL 1 TO JULY 31
0 LBS. RYE GRAIN @ 30 LBS./ACRE (NURSERY FOR FESCUE)
SID LBS. RYE GRASS @ 40 LBS./ACRE (TEMPORARY VEGETATION)
SEEDING DATES: DECEMBER 1 TO MARCH 30
LBS.
APPLY THE FOLLOWING:
13000 LBS. OF 10-10-10 FERTILIZER (1000 LBS./ACRE)
26 TONS OF DOLOMITIC LIME (2 TONS/ACRE)
1300 BALES OF SMALL GRAIN STRAW (100 BALES/ACRE)
ALL SURFACE DRAINS SHOULD BE INSTALLED PRIOR TO SEEDING. SHAPE
ALL DISTURBED AREA IMMEDIATELY AFTER EARTH MOVING IS COMPLETED.
APPLY LIME AND FERTILIZER THEN DISK TO PREPARE A 3 TO 4 INCH
SMOOTH SEEDBED. APPLY SEED AND FIRM SEEDBED WITH A CULTIPACKER
OR SIMILAR EQUIPMENT. APPLY MULCH AND SECURE WITH A MULCH
ANCHORING TOOL OR NETTING.

vay.+ scs
TYPES MATERIAL ENCOUNTERED IN BORIN(
(Use one of systems below)
UNIFIED CLASSIFICATION. -
USDA CLASSIFICATION
GW-Well graded gravels; gravel, sand mix_
. g-gravel
GP -Poorly graded gravels
s-sand
GM -Silty gravels-, ' gravel-sand silt mix'
..�,.;..
y vfs-vefine sand'
GC -Clayey gravels; gravel -sand -clay. mix ......
sI-sandy.loam.. :..... ......
SW -Well graded -sands; sand -gravel mix
fSl-fine Sandy.*"i
SP - Poorly graded sands' "
'
Ir.loam:
Sh,I silty sand: _...... :... ,: .
gl?g veU loam
SC-Clayeysands; sand-clay:mixtures- -•
'si=silt--.-.- -
ML= Silts; silty, v,finesands;sandyprelayeysil6:':.''sil=silt
. _.,.
loam..�:�:.�.�_ `:...- ""�"' '"'•-� � Z.
CL-Clays of low to medium plasticity -
cl - clay loam
CH - Inorganic clays of high plasticity
'sicI-silty clay loam
MH -Elastic silts -
scl -sandy clay loam
OL-Organic silts and silty clays, low plasticity
sic -silty clay
OH -Organic clays, medium to high plasticity
c-clay
1. Suitable material for embankment is aysilable 07eee F-I No pndlwu �•Ae., lora(.d on rh. sk.W an
,a,..,. ,rdo
REMARKS: G/!c.»../ -a / G./.r-c JF�qu.Q,/.� G r Jid,4 0,� �ysfl ,✓O
4AY-�.��d✓ / A,ia z .. sioG/c �,� r
/" R� M % /+ Gov ✓ FRt?/9 s J?o R . L J o .... .
`
G p Goo,✓ ias�oB SlG� s1.oPl� 3 • I , ..
.SN,�,i*r i=o,t L::nGw:✓ �iivii�+6 �'�¢yb��drhr✓TS, ,y3'
- Sp�egWriingspe qi✓. GIeJ ,O ,/��ocr.✓ (.ui'YG7 Loc .
2 Esplein hazards requiring epeasJ attention in design '1S.eLeoc a J�7•i Or''p+Y-,�y�✓
.
r
I 1 .
GENERAL. REMARKS::
p
24 25
26 27
26 29 30
31
32
33
34 35
36
37
36
3?
4o 41
42
43
44 45
46
47
48
49
50
61 -
LL_U
Nr
P1
I : -
11
Sc
P
SC
T
fi
G
/i,i2- Sc
/2-?SNI

i
2B'1.4' gr •OS` Sr•o..f' � .2B'bb e 92�"2-i 1 �'9�' " ./S' -
go:%
OL'/^' dG'1S" S9'1S" SL'bb" l iE'Lb`
G7
fe iS ` Sir / £S o>" bo oS'' 9S•6$
11 � j
l
�L fS{ aS~ zi 9n y•pb* y� �'c �Gb / F. J ET .
,
oS'r
k
r -
e�a,

POST OFFICE BOX 759 • ROSE HILL, NORTH CAROLINA 28458
[phone]
December 28, 1992
Mr. Mike Sugg
United States Department of Agriculture
Soil Conservation Service
P.O. Box 277
Kenansville, NC 28349
Subject: Proposed 3400•Sow Farm (Hairr Farm)
Dear Mr. Sugg:
Per Billy Jones' request, I have enclosed a readable copy of
the Northernmost corner of Lagoon #2. William Jones told me
that Billy was concerned about the 15' damn safety law, but as
you can see, we are well within its limitations. Per Billy's
request, we have also located the overhead powerline on the
enclosed farm grid. If you have any related questions, please
call me at [phone].
Sincerely,
Michael J. Blank
Project Engineer
cc: Mr. Billy Jones, Area Engineer

h '
\ \bx 3z 33,60
y '.r7 y?5. j;-- i �.,• 8r ;� K36 29
S•l� C���1r1 1 /;:= `' 39
4-1r-
F4./."� y4/;r7 y42J2r ,42,73 t-_1,?• y41.;o
y42.i= % 11
i�
}. 24 �3, j . ' ®-3.<; y93.92 y 44.30 C}a12.S7 \ p 42.5i n 42,41
I w�
•�ti y=:.L7 ;4n.a9 1.'^� 4-97 x43.94 y43.44 y47.42
6 3 '11 y 4b, /! 6,97 4S 0
- y � y 44.3, x41 3 9 y 38. S
47
•'7 1 ySo.SS y49,41 14B•97 IL8.1l96.F5
v1 77 y5i �a xso.2.o ` 18.47 x4f.21 ` yf3�# = 0.26
l t tX F
FArm
(VIIS'3 qoD Sari
f 9, 4r�a

AA�J9
006
71 %
------------
47 47.41 97
3 7 i4 z
S'2 03 S-1. 74 y v. 5-0
41
S 7j z .40 1 l
6i
.6f

l! �
-f` r�eE o // /i•.S'` GZ.:� �� �.\b_'` � 6S'Sb" �bs'{,{.'
'S,'��"i'�N,s'os" 5a'OS"- 9S'6$" _"YrS�' Wb2,}r" � �i•S-b�
bf / 9i� ro'h Gar .
k
1 �
i

Li46. ?�2
i-EEll 11 'IJ3 1C:II
P.
Operator:MURPHY FARMS, INC.County: DUPLIN Date: 02/11/93
Distance to nearest residence (other than owner): 1000.0 feet
1. STEADY STATE LIVE WEIGHT
0
Bore
(farrow to
finish)
x
1417
lbs.
= 0
lbs
0
sore
(farrow to
feeder)
x
522
lba.
= 0
lbs
0
head
(finishing
only)
x
135
lbs.
= 0
The
2050
sows
(farrow to
wean)
x
433
lbs.
= 887650
The
0
head
(wean to feeder)
x
30
lbs.
= 0
The
TOTAL STEADY STATE LIVE WEIGHT (SSLW) = . 887650 lbs
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 887650 lbs. SSLW x Treatment Volume(CF)/lb. SSLW
Treatment Volume(CF)/lb. SSLW= 1 CF/lb. SSLW
Volume = 887650 cubic feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
A-9-6
Volume = 0.0 cubic feat �( � ,)� N. "rjtt/
4. TOTAL DESIGN VOLUME
Inside top length 555.0 feet ; Inside top width 240.0 feet
Top of dike at elevation 47.8 feet
Freeboard 1.0 feet ; Side slopes 3.0 : 1 (Inside lagoon)
Total design lagoon liquid level at elevation 46.8 feet
Bottom of lagoon elevation 34.1 feet
Seasonal high water table elevation 38.6 feet
Total design volume using prismoidal formula
SS/EHD1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH
3.0 3.0 3.0 3. a 549.0 234.0 12.7
AREA OF TOP
LENGTH + WIDTH =
549.0 234.0 128466.0 (AREA OF TOP)
AREA OF BOTTOM
LENGTH • WIDTH =
472.8 157.8
AREA OF MIDSECTION
LENGTH • WIDTH • 4
510.9 195.9
74667.8 (AREA OF BOTTOM)
400341.2 (AREA OF MIDSECTION * 4)
CU. FT. _ [AREA TOP • (4•AREA MIDSECTION) • AREA BOTTOM] • DEPTH/6
128466.0 400341.2 74607.8 2.1
VOLUME OF LAGOON AT TOTAL DESIGN LIQUID LEVEL = 1277229 CU. FT.

FEE 11 '9='.' 16: 15 ,
r,.
5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
• Lagoon (top of dike)
Length • Width =
555.0 240.0 133200.0 square feet
Buildings (roof and lot rater)
Length • Width =
0.0 0.0 0.0 square feet
TOTAL DA 133200.0 square feet
Design temporary storage period to be 180 days.
5A. Volume of waste produced
Approximate daily production of manure in CF/LB SSLW 0.00136
Volume = 887650 Lbs. SSLN • CF of Waste/Lb./Day 180 days
Volume = 216769 cubic feet
5B. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A..
Volume = 0.0 gallons/day 180 days storage/7.48 gallons
per CF
Volume = 0.0 cubic feet
SC. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall = 7.0 inches
Volume = 7.0 in • DA / 12 inches per foot
Volume - 77700.0 cubic feet

FED: i� •y� ���.: )r, , f
P.4
5D. Volume of 25 year - 24 hour storm
• Volume = 7.5 inches / 12 inches per foot * DA
Volume = 83250.0 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 216769 cubic feet
58. 0 cubic feet
5C. 77700 cubic feet
5D. 83250 cubic feet
TOTAL 377719 cubic feet
G. SUMMARY
Total required volume 1265369 cubic feet
Total design volume avail. 1277229 cubic feet
Min. req. treatment volume plus sludge accumulation 887650 cubic fee
pp7e yyol
At elev. 43.5 feet'; Volume is 884000•cubic feet (end pumping)
Total design volume less 25yr-24hr storm is 1t93979 cubic feet
At elev. ILIS/.feet Volume is -44-5444bO. cubic feet (start pumping)
Seasonal high rater table elevation 1.2" feet
7. DESIGNED BY:L�PPROVED BY: ,
DATE: gll, .? DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
5

FCL L9 11:�r
P. 1'.
_�Lcwvl� reu n _ Z_
OPERATION AND MAINTENANCE PLAN
Thies lagoon is designed for waste treatment with minimum odor
control- The time required for the planned fluid level to be
reached may vary due to coil conditions, flushing operations, and
the amount of fresh water added to the system.
Land application of waste water is recognized no an acceptable
method of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent runoff from the field or damage
to trope.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre -
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste ('see Attachment B)
before land application.
3. Begins�T p-�out of the lagoon when fluid level reaches eleva-
tion 45. Sa marked by'permenent markers. Stop pump -out when
the fluid level 'reaches elevation 43.5 or before fluid depth is
less than 6 feet deep (this prevents the loss of favorable
bacteria) .
A. The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended maximum application rate is 0.4
inch per hour,
5. Keep vegetation on the embankment and areas adjacent to the
lagoon moved annually. vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
outlets.
8. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Environment, Health, and Retural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.

Typical View of a One —Stage Lagoon System
----------------------------
High End Pod Elevation:—
Low End Pod Elevation:-- t 15-___
Confinement
Building
Pit
t
Top width:_—za— — —
Settled Top Elevation:_/V 7. Y'
pipe (Needs to be
adequately supported)
M
Fluid Elevation:—Aly'—
\,_ FCrlue, 4 P,j; C
Treatment Lagoon
Depth
Bottom Elevation:__5__Y_'
Inside Side Slopes:-3:
Outside Side Slopes:-3.,—/

SPECIFICATIONS FOR CONSTRUCTION OF WASTE TREATMENT LAGOONS
Clearing:
All trees and brush shall be removed from the construction area
before any excavating or fill is started. Stumps will be removed
within the area of the foundation of the embankment and fill areas
and all excavated areas. All stumps and roots exceeding one (1)
inch in diameter shall be removed to a minimum depth of one (1)
foot. Satisfactory disposition will be made of all debris. The
foundation area shall be loosened thoroughly before placement of
-embankment material.
Cut-off Trench:
A cut-off trench (when specified) shall be installed as shown in
the plans. 7-o,,,C1,, Regci, -c c{ _ Sew {'Pcj
Soll �iJc.cff,�q /ate S4cc-A-
Construction:
Construction of excavated and earthfill areas shall be performed to
the neat lines and grades as planned. Deviations from this will
require prior approval of the SCS. Earthfill shall not be placed
in standing water and reasonable compaction of the fills shall be
performed by the construction equipment or sheeps-foot roller during
placement. The embankment of the lagoon shall be installed using
the more impervious materials. Construction of fill heights shall
include ten (10) percent for settlement. To protect against seepage,
when areas of unsuitable material are encountered, they will need to
be excavated a minimum of one (1) foot below grade and backfilled and
compacted with a suitable material (ie-CL,,SC,CH). Refer to the soils
investigation information in the plans for special considerations.
Precautions should be taken during construction to prevent excessive
erosion and sedimentation.
Vegetation:
All exposed embankment and other bare constructed areas shall be
seeded to the planned -type of vegetation as soon as possible after
construction.
A

Lf-3.v..
--r• 1-f- J' a ,3
SCS-ENG-538 i. S. DEPARTMENT OF AGRICULTURE
Re, 5-70 I ,7J✓r,n� SOIL CONSERVATION SERVICE
SOIL INVESTIGATION TO DETERMINE SUITABILITY OF PROPOSED POND SITF
am • • • ••
••• • • •• • •• • •
■■■■■■■■■■■■■■■■■■■■■■■■■■
■■■■■■■ems■■■■■■■e■e■■■■■■e
■■■
■■�:9
■■■■
►\
MEN
■■■■■■■■■
■■
u■■E■■■■■NINE
■■■■
■■MM■■■■■■■■■e■■■■■■■■ee
■■■■■ee■®■■■■■■M■■■■■■■®■■
■e■■e■eBIONCE'■■■e■e■■■NONE
■■ol■■�In-k
-,
©E■■■■=■■■■■■■■
e
mm
mi■Mi■IMiiiiie�■sei
OMEN
e■■■��eeei■■■■■■ee■e■i■■�eee
ee■■■®■e■■■®■■■e■■e■■■■ee■
MEN
■■■■■■■■■■■■■■■■■■■■■ee
eiii■ii�ii�■■■®■■s■i■ii:e�i
•
[®]I©I©I�1®i�!�I �^ �ImIEYII®I®Iml®!Dlmimlm101®I01�
®�9!■I■I■I■I■I
I
®I■I■I■I■I■I■I�rl■I■I■I■I■I■I■
®
010010I
I
■I■I■
MONK■
lalmI■i■�■�■I■
�r���■M■■I■1■MIM
M
I■I■
ME
1�1310MMI■
ME
mmim-lffllmi■I■I■1m
■
■1■1m1■I■1■l
ilmmimillmlal■
MSam
I■I■I■I■133m.
■i
I■I■I■!
l■I■I■I
1■I■I■
=mini
I■i■uI■lm
■1■l■i■1■!mil■I■I■I■I■I■I■
�
■■I■I
1■��l�mi■I■I�I■I■I■ICI■I■I■I■I■I■i■
�A!ml■I■!■I■!■I�I�I■I■�
I■!■I■I■I■I■I■i■I■I■I■
' •
allLei■i�i���!■®i■i■i■i■■i■i■i■i■�■i■�■i■i
TNb
lit�;%.+�jt rS.f..�.. fry-•r..%r.[' L/.t.�' �G6/JrC G✓.EST Ews o� ' •"" 6.^ o.✓ !�l'� /
/I/o L�l//• t�/r,• F'!-C c:..� - - r - _ 9/ ��1�•, !' ar E.l !', /�'r'-riJ'i��L�S�I,�'J

TYPES OF NIATERIAL ENCOUNTERED IN BORINGS
- (Use one of systems below)
UNIFIED CLASSIFICATION -
USDA CLASSIFICATION
GW-Well graded gravels; gravel, sand mix
g- gravel
GP -Poorly graded gravels - -
5-sand - - -
GM -Silty gravels; gravel -sand -silt mix
yfs-very fine sand.- - -
GC -Clayey gravels; gravel -sand -clay mix
sl- sandy loam ..
SW -Well graded sands; sand -gravel mix
fsl-fine sandy.loarn
SP-Poorly graded sands
!-.!Garr,.
SM-Silty sand
gl-gravelly loam. -
SC -Clayey sands; sand -clay mixtures
si-silt
ML -Silts; silty, v. fine sands; sandy or clayey silt
sil=silt loam
CL-Clays of low to medium plasticity
cl-clay loam -
CH -Inorganic clays of high plasticity -
sicl- silty clay loam
MH-Elastic silts -
scl-sandy clay loam
OL-Organic silts and silty clays, low plasticity
sic -silty clay
OH -Organic clays, medium to high plasticity
c - clay '
1. Suitable material for embankment is available E_e Q No f/ndfwte mh<r< l.tn an th. sketch on
m,ns< srd.) .
REMARKS: L./N co>,✓ 1Y G./.tl A'eg I'ellea L1.VX,< o.J f—= 'A /'�O rOR�
Or TTo,n „s .G ,��xsv.✓ %X �j ir�✓a 2 SToG /tC i�14.t S
/'•Q�yr /.A600 w/ "Vew?' _7 role LiN,rvfj e&7,41 446oO-1.
GAGoo.✓ /a,s/DI>t Sled Sl.>P�s 3'/ . Sri 'DES/G,✓ dor✓sj
% o,C `- A hoc ✓ L i/{�/N G I�H1��✓%11fN%S,
S'�6 NoTEs ✓ G.n i d lg ,e4j �✓,�.G�,�,W Loc
2. E>plain bazarde requiring epecis� attention ra/ des gn < e<, s < /"%i O�- d�-' �is!✓
� L c
GENERAL REMARKS: '
Be.7 � 9
rb.3
90125
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
Nr
ai
SC
S
sc
p
C
'
4,
r,
Ntt
C
I
s
C
L
G�
9 <-5
Noy c��
spFc
'J�odXj'
//-/7- Sc
/2-/ESN)

1
V 1 \
c
10
L �
w
"M ,
V
4
N
tl
�.'.
v-
vim.
!
�
I
I �F
t V'
�• 1,�
Ll
I.i
~'
1
fJ

State of North Carolina
Department of Environmen�gECEIVE
and Natural Resources 0 4 1998
Division of Water Quality MAY
James B. Hunt, Jr., Governor 112
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
April 29, 1998
Wesley Hairy
Hairy I Sow Farm
1188 Veach's Mill Rd
Warsaw NC 28398
lAt,4100
D E N R
Subject: Application No. 31-0200
Additional Information Request
Hairy I Sow Farm
Animal Waste Operation
Duplin County
Dear Wesley Hairy:
The Non -Discharge Permitting Unit has completed a preliminary engineering review of the
subject application. Additional information is required before we can continue our review. Please
address the following by May 29, 1998:
You have indicated on your permit application that your facility began operation in 1993. In
order to complete the various components of the certified animal waste management plan, please submit
two copies each of the following documents that may be applicable to your farm:
1. NRCS Site Evaluation Form (NC-CPA-17)
2. Hazard Classification Form (NC-ENG-34)
3. Wetland Determination
4. A credit for residual nitrogen from a leguminous crop such as soybean in a crop rotation
must be accounted for in the subsequent crop. Hence, nitrogen application rates to the crop
following a legume should be reduced by 15-30 lb. per acre depending upon the soil type.
Please revise your WUP to properly list all application rates with residual nitrogen
incorporated into your cropping scheme.
Please consult your technical specialist for further assistance in determining and obtaining
documents required for your farm. Please include an explanation if any of the above requirements do not
apply to your farm.
Please reference thq subject permit application number when providing the requested
information. All information should be signed, sealed, and submitted in duplicate to my attention at the
address below. The informationirequested by this letter, must be submitted on or before May 29, 1998 or
the Division will return your application as incomplete in accordance with 15A N.C.A.C. 2H .0200 and
your facility will be considered to be operating without a permit.
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10%, post -consumer paper

Application No. 31-0200
Wesley Hairr
Page 2
Please be advised that operation of the subject animal' waste management system without a valid
permit is a violation of North Carolina General Statute 143-215.1 and will subject you to the enforcement
authority of the Environmental Management Commission.
If you have any questions regarding this request, please call me at [phone], extension 363.
Sincerely,
J R Joshi
Soil Scientist
Non -Discharge Permitting Unit
cc: Wilmington Regional Office, Water Quality
Permit File

State of North Carolina
Department of Environment,
Health and Natural Resources
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
November 13, 1996
Wesley Hairr
Hairr I Sow Farm
1224 Veach's Mill Rd
Warsaw NC 28398
SUBJECT: Operator In Charge Designation
Facility: Hairr I Sow Farm
Facility ID#: 31-200
Duplin County
Dear Mr. Hairr:
Senate Bill 1217, An Act to Implement Recommendations of the Blue Ribbon Study
Commission on Agricultural Waste, enacted by the 1996 North Carolina General Assembly,
requires a certified operator for each animal waste management system that serves 250 or more
swine by January 1, 1997. The owner of each animal waste management system must submit a
designation form to the Technical Assistance and Certification Group which designates an
Operator in Charge and is countersigned by the certified operator. The enclosed form must be
submitted by January 1, 1997 for all facilities in operation as of that date. Failure to designate a
certified operator for your animal waste management system is a violation of 15A NCAC 2H
.0224 and may result in the assessment of a civil penalty.
If you have questions concerning operator training or examinations for certification, please
contact your local North Carolina Cooperative Extension Service agent or our office.
Examinations have been offered on an on -going basis in many counties throughout the state for
the past several months and will continue to be offered through December 31, 1996.
Thank you for your cooperation. If you have any questions concerning this requirement please
call Beth Buffington or Barry Huneycutt of our staff at 919/733-0026.
Sincerely,
A. Preston Howard, Jr., P.E., Jirector
Division of Water Quality
Enclosure
cc: Wilmington Regional Office
Water Quality Files
P.O. Box 27687, �Raleigh, North Carolina 27611-7687 N%f An Equal Opportunity/Affirmative Acton Employer
Voice 919-715-4100 50% recycled/10% post -consumer paper

ENV. INVESTIGATIONS TEL:[phone]
Wilmington Regional Office �a`tJFS�
Department of Environmental Management
ATTN: Dave Holsinger
127 Cardinal Drive Extension
Wilmington, NC 28405
Re: Request for Site Visitation of Listed Hog Farms
Dear Mr. Holsinger:
Jul 08 96 9:39 No.006 P.01
yax1� A
10'91L��11
���,s�1oJmact'
I would like to request a faxed copy of the most recent site visitation record for the below listed
hog farms.
Wesley Hairr
272.83-Acre Property
1189 Veaches Mill Road
Warsaw, NC
Duplin County
Wesley Hain
226.16-Acre Properly
2806 Halfway Branch Road
Ivanhoe, NC
Pender County
Please fax this information to the attention of Kim Hunt at 919-544-2199. if you have any
questions or need additional information you may contact me at 919-544-7500. 'thank you for
your assistance.
V.mbinreY ly,LJ�O
crl H
Environmental Scientist
post-N'Fax Note 7671
rsa
nay
To
{
F7om U
co
CO.
Phone B
Pholw 1 81U
Fee it
Fax

a
N.C. DIVISION OF ENVIRONMENTAL MANAGEMENT
COMPLAINT/EMERGENCYREPORT FORM, l
REGIOMIL OFFICE V o Date/Time:
Emergency: Complaint: County: ��te 2
Repor% Received From:
Agency:
Phone No.
Complainant: 11a;rl- //(.�nw ij-;)r M
Address: /%J'P 113PPCh Saw lii / 1 o i , Phone No.
Complaint or Incident: `� &'^52 l` ' /VC
Time and Date Occurred:
Location of Area Affected:
Surface Waters Involved: �—
Other Agencies/Sections Notified:
OtherDetails:
rz�
Groundwater Involved: E 1
Investigator: Date
EPA Region IV [phone] Pesticides 733-3556
Emergency Management 733-3867 Wildlife Resources 733-7291
Solid and Hazardous Waste 733-2178 Marine Fisheries 726-7021
Water Supply Branch 733-2321 U.S. Coast Guard MSO 343-4881
127 Cardinal Drive Exteuaion, Wilmington, N.C. 28405-3845 • Telephone [phone] • Fax [phone]
An Fquel opportunity AfScmative Action Employer

State of North Carolina
Department of Environment,
Health and Natural Resources • •
Division of Environmental Management
James B. Hunt, Jr., Governor ma`s
IL
Jonathan B. Howes, Secretary ED F
A. Preston Howard, Jr., P.E., Director
March 21, 1994
Wesley Hairr
Rt 2 Box 299-E
Warsaw NC 28398
Dear Mr. Hairr:
This is to inform you that your completed registration form required by the recently
modified nondischarge rule has been received by the Division of Environmental Management
(DEM), Water Quality Section.
On December 10, 1992 the Environmental Management Commission adopted a water
quality rule which governs animal waste management systems. The goal of the rule is for animal
operations to be managed such that animal waste is not discharged to surface waters of the state.
The rule allows animal waste systems to be "deemed permitted" if certain minimum criteria are
met (15A NCAC 2H .0217). By submitting this registration you have met one of the criteria for
being deemed permitted.
We would like to remind you that existing feedlots which meet the size thresholds listed
in the rule, and any new or expanded feedlots constructed between February 1, 1993 and
December 31, 1993 must submit a signed certification form (copy enclosed) to DEM by
December 31, 1997. New or expanded feedlots constructed after December 31, 1993 must
obtain signed certification before animals are stocked on the farm. Certification of an
approved animal waste management plan can be obtained after the Soil and Water Conservation
Commission adopts rules later this year.
We appreciate you providing us with this information. If you have any question about
the new nondischarge rule, please contact David Harding at [phone].
Sincerely,
a
Steve Tedder, Chief
enc: Water Quality Section
P.O. Box 29535, Rdeigh, North Cororina 27626-0535 Telephone [phone] . FAX [phone]
An Equal Opportunity Affirmative Action Employer 50%recycled/ 10%post-consumer paper

J-?
H UEEC 1983 r,
REGISTRATION FORM FOR ANIMAL FEEDLOT OPERATffbNS ;_
Department of Environment, Health and Natural sourcesQy,,, 4
Division of Environmental Management !.,nnin
G
Water rand C'%
Quality Section
If the animal waste management system for your feedlo d.
is designed to serve more than or equal to 100 head.'f cattle,
ft =
horses, 250 swine, 1,000 sheep, or 30,000 birds theare rved
by a liquid waste system, then this form must be f;illedpgpt^,%)nd
mailed by December 31, 1993 pursuant to 15A NCAC 2H.0217 (c) in
order to be deemed permitted by DEM. Please print clearly.
Farm Name: Hairr Farm
Route 2 Box 299-E.
Warsaw, NC 28398
Duplin County
Owner(s) Name:
Manager(s) Name:
Lessee Name:
i (y
wi. J
919-293-3036
Take US 117 N to Warsaw; at stop light,
turn Rt. onto NC 24 E to edge of town
where NC 24 and NC 50 merge; take SR 1300
(Ward's Bridge Rd) E for 1.5 miles; turn
Lt. onto SR 1350 for 1.0 mile; turn Rt.
Farm Location (Be as specific as poss'ble onto SR 1305 for 1.4 miles; go thru
direction, milepost, etc,.): F+.w o+�•. rp intersection of SR 1305 and SR 1301 onto
Latitude/Longitude if known
SR 1307 for 3.0 miles to farm entrance on
Lt. Farm about 0.7 mile off SR 1307.
(NOTE: Farm entrance 1.0 mile past
Veaehes Kill Store. After turning Lt.
into farm complex, Hairr Farm will be Lt.
While Eco 12 will be Rt).(TT-26 min.; TD-
21 miles)
QBSP # 15-144-09-09
Design capacity of animal waste management system (Number and
type of confined animal (s) : 3
Average animal population on the9^1rm (Number and type of
animal(s) raised): �✓ev� a GeST '^� � 3dfoM
L"rsdd-1 10- /dn 3•TO
Year Production Began: 19y 3 ASCS Tract No.:
Type of Waste Management System Used: Aid+✓ake Li4wt r ra✓ :✓+•ba+:ok
Acres Available for Land Appl'cation of Waste: Zoo
e
Owner(s) Signature(s):
Date: 7-xa -13
Date:
(Doug LeMart, Serviceman)
31-aw