310136_HISTORICAL_20171231

NORTH CAROLINA
Department of Environmental Qual

Nutrient Management. Plan or Animal Waste Utilization
.04-2 =2015
This plait -has �been-prepared for:- This plan has-been developed by:
Bill McKay Ronnie.-G. Kennedy Jr.
William P McKay Agriment Services, Inc.
516 Gurman'Powell Road PO Box-1096
Kenansville, NC 28349 ' Beulaville, NC 28518
(910) 296-0.396 252-568-2648 .
veloper Signature
Type of Plan: Nitrogen Only with:l�ianure Only
Owner/Manager/Producer Agreement
L(we) understand and' agree to the specif cations and the operation and maintenance
procedures established in this -nutrient management plan which includes an animal
waste utilization plan for the farm named above. I have read and understand the
Required Specifications con cerning,anim 1.waste management that are included with
this plan.
Signature (owner) Date
Signature Date
Cj'W/!'P r
This plan meets the minimum standards an4 specifications of the U.S. Department of
Agriculture - Natural Resources Conservati n Service or the standard of practices
adopted by the Soil and Water Conserv.ati.or Commission..
Plan Approved By:
PP ,
echnical Specialist Sigtta e, Date
�'' 761456 Database Version 4.1 . Date Printed: 04-28-2015 Cover Page i

Narrative
(4/28/2015)
This plan adds 2 acres of honey wagon and changes fields 1, 2, and 3 to bermuda pasture/small
overseed.
(10/12/1999)
Waste Plan is a revision of the 12/13/1995 Plan completed by Tech Specialist Johnny L. Lanier. This
plan represents the acres as depicted by the wettable acre determination.
Lagoon has enough storage for 135 the crops of coastal hay with -small grain overseed will allow
pumping every 135 days.
All soils in this plan have an instantaneous loading of .5in./hr. not to exceed 1.Oin./per event.
No waste should be applied to a crop that does not have a realistic yield for the usage of irrigated sw'r
waste except for preplant. All fields must meet monitoring and reporting requirements when used. M
Mckay plans to appy swine waste in accordance with his specific waste analysis not to exceed the
hydraulic loading of the soils. Mr. Mckay may use cattle to remove small grain in winter months.
*Honey wagon will be used on fields 2, 3, and 4 on the map. ACC contracting will supply as
761456
----------------------------------
Database Version 4.1
---------------
Date Printed: 04-28-2015
Narrative Page 1 of

I
The table shown below provides a summary of the crops or rotations included in this plan for each field. Realistic
I Yield estimates are also provided for'each crop in the plan. In -a d_ition, the Leaching Index for each field his shown,
where.available. - -
i _
Planned Crops Summary
I
Tract
Field
Total
Ades
Useable
Acres
Leaching
Index (LI)
Soil Series
Crop Sequence
RYE
4224
1
8.49
8.49
NIA
Craven
I
Small Grain Overseed
I
1.0 Tons
Hybrid Bermudagrass Pasture
I
5.5 Tons
4224
2
11.47
- 11.47
NIA
Craven
I
Small Grain Overseed
I
1.0 Tons
_
I I
Hybrid Bermudagrass Pasture
I
5.5 Tons
4224
3
1.12
1.12
NIA
Autryville I
Small Grain 0mrsmd
1.0 Tons
Hybrid Bermudagrass Pasture I
5.5 Tons
4224
4
1.401
1.40
NIA
Norfolk i
Small Grain Overseed I
1.0 Tons
Hybrid Bermudagrass Hay I
6.5 Tons
4224
5
1.03
1.03
NIA
Norfolk
Small Grain Overseed
1.0 Tons
jI
Ii
Hybrid Bermudagrass Hay i
6.5 Tons
4224
5 (HV4)
1 2,00
200
NIA
Norfolk I
Small Grain Overseed
1.0 Tons
Hybrid Bertnudagrass Hay I
6.5 Tons
PLAN TOTALS: 25,51 25.51
Llw
�?Potntral�L°eachrn
T'echme`al=Gutdattce
.-a
:-
r
Low potential to contribute to soluble
None
f
2
nutrient leaching below the root zone.
i
Moderate potential to contribute to
Nutrient Management
(590)
should be planned.
>= 2 &
soluble nutrient leaching below the root
<= 10
zone.
High potential to contribute to soluble
Nutrient Management (59�)
should be planned. Other conservation practices that improve
nutrient leaching below the root zone.
the soils availa6lewater h
Wing capacity and improve nutrientuse efficiency should be
> 10
considered. Examples are
Cover Crops (340) to scavenge nutrients, Sod -Based Rotations
(328), Long -Term No-Tilii
(778), and edge -of -field practices such as Filter Strips (393) and
Riparian ForestlBut%rs (391).
761456 Database Version 4.1
NOTE: Symbol * means user entered data.
Date Printed 4/28/2015
PCS Page 1 of

The Waste Utilization table shown below summarizes the waste utilization plan for this operation. This plan provides an estimate of the number of acres of
cropland needed to use the nutrients being produced. The plan requires consideration of the realistic yields of the crops to be grown, their nutrient requirements,
and proper timing of applications to maximize nutrient uptake.
This table provides an estimate of the amount of nitrogen required by the crop being grown and an estimate of the nitrogen amount being supplied by manure or
other by-products, commercial fertilizer and residual from previous crops. An estimate of the quantity of solid and liquid waste that will be applied on each field in
order to supply the indicated quantity of nitrogen from each source is also included. A balance of the total manure produced and the total manure applied is -
included in the table to ensure that the plan adequately provides for the utilization of the manure generated by the operation.
Waste Utilization Table
Year 1
Tract
Field
Source
ID
Soil Series
Total
Acres
Use.
Acres
Crop
RYE
Applic.
Period
Nitrogen
PA
Nutrient
Req'd
(Ibs/A)
Comm
Fert.
Nutrient
Applied
Qbs/A)
Res.
Obs/A)
Applic.
Method
Manure
PA
Nutrient
Applied
(Ibs/A)
Liquid
ManwrA
'Ppbed
(acre)
Solid
Manure
Applied
(acre)
Liquid
Manure
Applied
(Field)
Solid
Manure .
Applied
(Field)
N
N
N
N
1000
gal/A
Tons
1000 gals
tons
4224
1
S7
Craven
8.49
8.49
Small Grain Overseed
1.0 Tons
10/1-3/31
50
0
0
Irrig.
50
27.74
0.00
235.53
0.0
4224
1-
S7.
Craven .
8.49
8.49
Hybrid Bermudagrass Pasture
5.5 Tons
3/1-9/30
174
0
0
Irrig.
174
96.53
O.00
819.65
0.0
4224
2
S7
Fraven
11.47
11.47
Small Grain Overseed
1.0 Tons
1011-3/31
50
0
0
Irrig.
50
.' 27.74
0.0
318.17
0.00
4224
2 l
S7
Craven .
11.47
11.47
Hybrid Bermudagrass Pasture
5.5 Tons
3/1-9/30
174
0
0
Irrig.
174
' 96,53
0.00
1,107.22
0,00
4224
3-"
S7
Autryville
1.12
1.12
Small Grain Overseed
1.0 Tons
10/1-3/31
50
0
0
Irrig.
50
27.74
0.00
31.07
0.00
4224
3'�;
S7
Autryville
_-4.12
1.12
Hybrid Bermudagrass Pasture
5.5 Tons
311-9/30
202
0
0
brig.
202
112.07
0.00
125,51
0.00
4224
4
'S7
Norfolk
1.40
1.40
Small Grain Overseed
1.0 Tons
10/1-3/31
50
0
0
Irrig.
-. 50
27.74
0.00
38,84
0.0
4224
4A
S7
Norfolk
1.40
1.40
Hybrid Bermudagrass Hay
6.5 Tons
3/1-9130
296
0
0
brig.
29
164.22
0.0
229.90
0.00
4224
5. -
S7
Norfolk
1.03
1.03
Small Grain Overseed
1.0 Tons
10/1-3/31
50
0
0
Irrig.
5
27.74
0.00
28,60
0.0
4224
15
S7
Norfolk
1.03
1.03
Hybrid Bermudagrass Hay
6.5 Tons
3/1-9/30
296
0
0
Irrig.
296
164.22
0.00
169.31
0.00
4224
5 (HW)
S7
Norfolk
2.00
2.00
Small Grain Overseed
1.0 Tons
10/1-3/31
'50
0
0
Irrig.
50
27.74
0.00
55.48
0.00
4224
5 (HW)
S7
Norfolk
2.00
2.00
Hybrid Bermudagrass Hay
6.5 Tons
311-9/30
296
0
0
Irrig.
296
164.22
0.00
328.43
0.0
761456 Database Version 4.1 Date Printed. 4/28/2015 WUT Page 1 of 2

Waste Utilization Table
VPar 1
Tract
Field
Source
ID
Soil Series
Total
Acres
Use.
Acres
Crop
RYE
Applic.
Period
Nitrogen
PA
Nutrient
Req'd
(Ibs/A)
Cornm
Fert.
Nutrient
Applied
Qbs/A)
Res.
Obs/A)
Applic.
Method
Manure
PA
Nutrient
Applied
Qbs/A)
Liquid
ManureA
pplied
(acre)
Solid
Manure
Applied
(acre)
Liquid
Manure
Applied
(Field)
Solid
Manure
Applied
(Field)
N
N
N
N
1000
gal/A
Tons
1000 gals
tons
Total Applied, 1000 gallons
3,487.69
Total Produced, 1000 gallons
3.403.9
Balance, 1000 gallons
-83.75
-Total Applied, tons
0.00
Total Produced, tons
0.00
Balance, tons
WON0.00
Notes: 1. In the tract column, — symbol means leased, otherwise, owned. 2. Symbol * means user entereddata.
r,
761456 Database Version 4.1
Date Printed: 4/28/2015
WUT Page 2 of 2

The Irrigation Application Factors for each field in this 'lan are hown in the following table. Infiltration rate varies
with soils, If applying waste nutrients through an irngavon system, you must apply at a rate that will not result in
runoff. This table provides the maximum application rate per hour that may be applied to each field selected to
receive wastewater. -It also lists the maximum application amount that each field may receive in any one application
event:. - 1
Irrigation Application Factors j
Tract
Field
Soil Series
Application Rate
(inches/hour)
Application Amount
(inches)
4224
1
Craven
I
0.40
1.0
4224
2
Craven
0.40
1.0
4224
3
Autryville
0.60
1.0
4224
4
Norfolk
0.50
1.0
4224
5
Norfolk
0.50
1.0
4224
5 (HW)
INorfolk
0.50
1.0
761456 Database Version 4.1 Date Printed 4 I8/2015 1AF Page 1 of I
NOTE: Svmbol * means user entered data.

The following Lagoon Sludge Nitrogen Utilization tab a provides an estimate of the number of acres needed for
sludge utilization for the indicated accumulation perio 1. Thes estimates are based on average.nitrogen
concentrations for each source, the number of animals in the f ility and the plant available nitrogen application
rates shown in the second column �
Lagoon sludge contains nutrients and organic matter r maining.after treatment and application of the effluent. At
clean out, this material must be utilized for crop production anal applied at agronomic rates. In most cases, the
priority nutrient is nitrogen but other nutrients includir g phosplorous, copper and zinc can also be limiting. Since
nutrient levels are generally very high, application of s ludge m st be carefully applied.
Sites must first be evaluated for their suitability for sI dge app ication. Ideally, effluent spray fields should not be
used for sludge application. If this is not possible, car should betaken not to load effluent application fields with
high amounts of copper and zinc so that additional effluent c not be applied. On sites vulnerable to surface water
moving to streams and lakes, phosphorous is a concern. Soils ontaining very high phosphorous levels may also
be a concern.
Lagoon Sludge Nitrogen Utilization Table
Crop
Maximum
PA-N Rate
lb/ac
Maximum Sludge
Application Rate
1000 gal/ac
minimum
5 Year.;
A
Accum
s
lation
Minimum Acres
10 Years Accumulation
Minimum Acres
15 Years Accumulation
Swine: Feeder -Finish
Lagoon
Sludge - Standard
Corn 120 bu
150
14.69
41.25
82.50
123.75
Hay 6 ton R.Y.E.
300
29.38
20.62
41.25
61.87
Soybean 40 bu
160
15.67
38.67
77.34
1 t6.01
--------------
761456
------------- - ---------------------------
Database Version 4.1
--------------------
I P ' ted: 04-28-2015
-----------------------------
Sludge Page 1 of 1

The Available Waste Storage Capacity table provides an estimate of the number of days of storage
capacity available at the end of each month of the Ian. A ailable storage capacity is calculated as the
design storage capacity in days minus the number of days of net storage volume accumulated. The start
date is a value entered by the user and is defined -.the da'e prior to applying nutrients to the first crop in
the plan at which storage volume in the lagoon or olding and is equal to zero.
Available storage capacity should be greater thanor equal to zero and less than or equal to the design
storage capacity of the facility. If the available storage capacity is greater than the design storage
capacity, this indicates that the plan calls for the a plicatian of nutrients that have not yet accumulated.
If available storage capacity is negative, the estimated volume. of accumulated waste exceeds the design
storage volume of the structure. Either of these sip ations indicates that the planned application interval
in the waste utilization plan is inconsistent with a structure's temporary storage capacity.
Awadahla Waste Ctnraae (annr4w
Source Name
I Swine Feeder -Finish Lagoon Liquid
Design Storage Capacity (Days)
Start Date
9/1
135
Plan Year
lonth
Available Storage Capacity (Days)
1
1
32
1
2
15
1
3
:. 29
4
'44
1
5
Y.58
1
6
73
1
7
87
1
I
g
; :'101
1
10
:`100
1
11
'81
1
12
61
* Available Storage Capacity is calculat
----------------------------------- ----------------------
761456 Database Version 4.1
th.
-------• ----------------------------------------
I-2015 Capacity Page 1 of. l

Required Specifications Fair,
Waste Management
1. Animal waste shall not reach sur,ace,w kters of the state by runoff, drift,
manmade conveyances, direct ap pikati n or direct discharge during
operation or land application. AE y,disc iarge of waste that reaches surface
water is prohibited.
2.
3.
There must be documentation in the de
either owns or has an agreement for us,
properly apply the waste. If the produe
properly dispose of the waste;'slie�sh
agreement with a landowner, wh is wi
allowing hihAerth'e-'4u's-iD-of;th"e'-,712 nd foe
responsibility of the owner of the waste
update of the Nutrient Management PI:
operation, increase in the number of an
receiving crop type, or available land.
Animal waste shall be applied to eet,
for realistic"crop yields. based up n'soil
data, climatic conditions, and lev 1 of n
regulations that restrict the rate f app
4. Animal waste shall be applied to
and e
.per year. Waste may be applied
land
acre per year but less than 10 to
s per
strips are installed where runoff
eaves
Office Technical Guide Standar
393 -
sign folder that the producer
of adequate land on which to
.r does not own adequate land to
ill provide evidence of an
hin a reasonable proximity,
waste'application. It is the
production facility to secure an
n when there is a change in the -
[mats, method of application,
ut not exceed, the nitrogen needs
ype, available moisture, historical
inagement, unless there are
cations for other nutrients.
•oding less than 5 tons per acre
eroding at more than 5 tons per
acre per year provided grass filter
the field (see USDA, MRCS Field
Filter Strips).
5. Odors can be reduced by injecti 'g the aste or by disking after waste
application. Waste should not be appli d when there is danger of drift
from the land application field.
6. When animal waste is to be appl' d on
will be soil incorporated -on convention-,
applied to conservation tilled cro s or
broadcast provided the applicatii in doe
to flooding (see "Weather and C # mate
cres subject to.flooding, waste
lly tilled cropland. When waste is
•assland, the waste may be
not occur during a season -prone .
n North Carolina" for guidance).
----------- - -- -- 1
761a56 Database Version 4.1 ate Printed: 4/28/2015 Specification Pale 1
ri

7. Liquid waste shall be applied':at lates.n
rate such .that runoff does not occur off
method which does not cause dri frorr
ponding should'occur in order to contri
S. Animal waste shall not be-app ied to sai
events, or when the soil surface is frozei
9. Animal waste shall he applied on active
that the crop is not covered with ante
growth. The potential for salt da age 1
considered.
t to exceed the soil infiltration-
ite or to. surface waters and in a
the site during application. No
l odor and flies.
rated soils; during rainfall
growing crops in such a manner
a depth that would inhibit
m animal waste should also be
10. Nutrients from waste shall not be appli d in fall or winter for spring
planted crops on soils with a high p' oten al for.leaching. Waste/nutrient
loading rates on these soils shouk be h d to a minimum and a suitable
winter cover crop planted to take up released nutrients. Waste shall not
be applied more than 30 days pri r to planting of the crop or forages
breaking dormancy.
11. Any new swine facility sited on Oil after ctober 1,1995 shall comply with
the following: The outer perimet r of t e land area onto which waste is
applied from a lagoon that is a co pon nt of a swine farm shall be at least
50 feet from any residential. prop rty b undary and canal. Animal waste,
other than -swine waste from facilities si ed on. or after October 1,1995,
shall not be applied closer that 25 feet to perennial waters.
12. Animal. waste shall not be; apvlii
13. Animal waste shall not be applic
than those owned by the landow
14. Waste shall be applied in a
public right-of-ways.
761456 Database Version 4.1
loses jhan,400 feet. to wells..:
r:
not
ate Print
than 200 feet of dwellings other
reach other property and
7.
.d: 4/28/2015 Specification Page 2
9

15. Animal waste shall not be.discha
or wetlands by a discharge or.by
applied to prior converted cropla
approved as a land application si
waste shall not be applied on gra
into water courses, and on other,
applied at agronomic rates in a n
from the site.
16. Domestic and industrial waste fr
sinks, etc., shall not be discharge
system.
17. A protective cover of appropriate
disturbed areas (lagoon embanks
shall be fenced, as necessary, to p
trees, shrubs, and other woody sl
considered appropriate. Lagoon
accessible. Berms and structures
evidence of erosion, leakage, or di
18. If animal production at the facili
owner,is responsible for-obtainic
which will eliminate the possibili
erosion.
ged into surface waters, drainageways,
wer-s -raying;, -Animal waste.may-be
id prc vided the fields have been
e by a "technical specialist". Animal
sed waterways that discharge directly
yasse waterways, waste shall be
anner that causes no runoff or drift
in wa hdown facilities, showers, toilets,
into 4he animal waste management
:ge tion will be established on all
its,, ins, pipe runs, etc.). Areas
tectihould
he vegetation. Vegetation such as
ies,tc., are limited to areas where
eas be kept mowed and
oulbe inspected regularly for
is to be suspended or terminated, the
and -implementing a "closure plan"
of a4 illegal discharge, pollution, and
19. Waste handling structures, pipin
.,
, pumps,
reels, etc., should be inspected
on a regular basis to prevent bre
kdow
s, leaks, and spills. A regular
maintenance checklist sho=on
t o
site.
20. Animal waste can be used
hat includes vegetables and other
crops for direct human consump
'on. However,
if animal waste is used on
crops for direct human consump
'on; it
should only be applied pre -plant
with no further applications of a
imal
I waste during the crop season.
21. Highly visible markers shall be installed
g Y
to -mark to and bottom
P
elevations of the temporary storage
i
(pumping
volume) of all waste
treatment lagoons. Pumping shad
be managed
to maintain the liquid level
between the markers. A marker
Will be
required to mark the maximum
storage volume for waste storage
ponds
----------------------------------------------------------------
761456 Database Version 4.1
-----------
Date Prin
-----------------------.---------------- ------------------
ed: 4/28/2015 Specification Page 3

22. Waste shall be tested within 60 d� ys of utilization and soil shall be tested
at least annually at crop sites wh
re waste products are applied. Nitrogen
shall be the rate -determining nut
lent, unless other restrictions require
waste to be applied based* on oth•
r'nutrients resulting in a lower
application rate than a nitrogen
aced rate. Zinc and copper levels in the
soils shall be monitored and.alte
ative crop sites shall be used when
these metals approach excessive 1 vels. pH shall be adjusted and
maintained for optimum crop production.
Soil and waste analysis
records shall be kept for a minim
am of five years. Poultry dry waste
application records shall be maintained
for a minimum of three years.
Waste application records for all
other waste shall be maintained for five
(5) years.
23. Dead animals will be disposed of
n a manner that meets North Carolina
regulations.
---
----------'------------------------------- -------------.._._
761456 Database Version 4.1 ate Printed: 4/28/2015 Specification Page 4

�-.R}i'L.R i - .-
Crop Notes
he following crop note applies to fteld(s): 4, 5, 5 (HW)
Bermudagrass Coastal Plain, Mineral Soil, Moder itely Well Drained.
Adaptation: Well -adapted.
In the Coastal Plain, hybrid bermudagrass sprigs c
deep (1.5" optimal). Sprigs should be planted quic
wind: For Coastal and Tifton 78 plant at least 101
rate of 30 bu/ac is satisfactory to produce full groi
conditions: Tifton 44 spreads slowly; so use at lea
For broadcast/disked-in sprigs use about 60 bulac.
potassium and micronutrients to apply preplant ar
the establishment year in split applications in Apr
Ib/ac N annually in split applications, usually in .4
Reduce N rates by 25% for grazing. Refer to NC!
of Pastures and Forages in North Carolina for moi
extension agent for assistance.
Small Grain: CP, Mineral Soil, low -leachable
In the Coastal PIain, oats and barley should be ph
October 15-November 20. For barley, plant 22 se,
each week seeding is delayed beyond the optimur
seeding rate modifications in the current NCSU "
initial seeding rate by at least 10% when planting
rye at 1-1 1/2 bushels/acre. Plant all these small g
essential. Review the NCSU Official Variety "gre
select a high yielding variety with the characteris
than 30 lbs/acre N at planting. Phosphorus and pc
this time. The remaining N should be applied dur
ui.be planted Mar. 1 to Mar. 31. Cover sprigs 1" to 3"
cly after digging and not allowed to dry in sun and
d/ac in'T rows, spaced 2' to 3' in the row. Generally a
ndcover in one or two years under good growing
t 40 bu/ac in 1.5' to 2' rows spaced 1' to 1.5' in row.
Soil test for the amounts of lime, phosphorus,
I for annual maintenance. Apply 60 to 1001b/ac N in
l and July. For established stands apply 180 to 240
aril and following the first and second hay cuts.
U Technical Bulletin 305 Production and Utilization
information or consult your regional agronomist or
The following crop note applies to field(s): 1, 2
ted from October 15-October 30; and rye from
l/drill row foot and increase the seeding rate by 5% for
time. See the seeding rates table for applicable
nall Grain Production Guide". Also, increase the
o-till. Oats should be planted at 2 bushels/acre and
sins at 1-1 1/2" deep. Adequate depth control is
n book" and information from private companies to
-s needed for your area and conditions. Apply no more
tsh recommended by a soil test can also be applied at
g the months of February -March.
----------------------------------------------------------------------- .----------------------------------------------------------------
761456 Database Version 4.1 Date Printed: 04-28-2015 Crop Note Page
e I of 3

Small Grain: CP, Mineral Soil, medium leachable
In the Coastal Plain, oats and barley should be plat
October 15-November. 20. For barley, plant 22 seei
each week seeding is delayed beyond the optimum
seeding rate modifications in the current .NCSU "S
initial seeding rate by at least 10% when planting r
rye at 1-1 1/2 bushels/acre. Plant all these small-gr
essential. Review the NCSU Official Variety ""' ee
select a high yielding variety with the characteristi
than 30 lbs/acre N at planting. Phosphorus and pot
this time. The remaining N should be applied durir
Small Grain: CP, Mineral Soil, medium leachable
following crop note applies to feld(s): 4, 5, 5 (HW)
.ed from October 15-October 30; and rye from
/drill row foot and increase the seeding rate by 5% for
:ime. See the seeding rates table for applicable
hall Grain Production Guide". Also, increase the
-till..Oats'should be planted at 2 bushels/acre and
ins at 1-1- 1/2". deep. Adequate depth control is
1 book" and information from private companies to
s needed for your area and conditions. Apply no more
sh recommended by a soil test can also be applied at
the months 'of February -March.
The following crop note applies to field(s): 3
In the Coastal Plain, oats and barley should be-pl. from October 15-October 30; and rye from
October 15-November 20. For barley, plant 22 see drill row foot and increase the seeding rate by-_5% for
each week seeding is delayed beyond the optimum time. See the seeding rates table for applicable '
seeding rate modifications in the current NCSU "Small Grain Production Guide". Also, increase'the
initial seeding rate by at least 10% when planting no -till. Oats should be planted at 2 bushels/acretand
rye at 1-1 1/2 bushels/acre. Plant.all these small gr iins at 1-1 1/2" deep. Adequate depth control is�
essential. Review the NCSU Official Variety. "gret n book" and information from private companies to
select a high yielding variety with the characteristics needed for your area and conditions. Apply no more
than 30 lbs/acre N at planting. Phosphorus and ppti
h recommended by a soil test can also be applied at
this time. The remaining N should be applied durthe months of February -March.
--------------------------------------------------------------------------
761456 Database Version 4.1 .' ' Date
ited: 04-28-2015
Crop Note Page 2 of 3

. ,.S. H,
The following crop note applies to field(s): 1, 2
Bermudagrass CP,. Mineral Soil, Poorly Drained t4, Somewhat Poorly Drained. -
Adaptation: Effective artificial drainage MUST b in place to achieve Realistic Yield Expectations
provided for these soils.
In the Coastal Plain-, hybrid bermudagrass sprigs c be planted Mar. 1 to Mar. 31. Cover sprigs 1" to 3"
deep (1.5" optimal). Sprigs should be planted quic cly after digging and not allowed to dry in sun and
wind. For Coastal and Tifton 78 plant at least 10 btu ac in 3' rows, spaced 2' to 3' in the row. Generally a
rate of 30 bu/ac is satisfactory to produce full groindcover in one or two years under good growing
conditions. Tifton 44 spreads slowly, so use at le t 40 bu/ac in 1.5' to 2' rows_spaced 1' to 1.5' in row.
For broadcast/disked-in sprigs use about 60 bu/ac: Soil test for the amounts of lime, phosphorus,
potassium and micronutrients to apply preplant an for annual maintenance. Apply 60 to 100 lb/ac N in
the establishment year in split applications in April and July. For established stands apply 180 to 240
lb/ac N annually in split applications, usually in Aril and following the first and second hay cuts.
Reduce N rates by 25% for grazing. Refer to NCjU Technical Bulletin 305 Production and Utilization
of Pastures and Forages in North Carolina for more information or consult your regional agronomist_ or
extension agent for assistance.
The following crop note applies to field(s): 3
Bermudagrass: CP, Mineral Soil, Moderately Well Drained.
Adaptation: Well -adapted.
In the Coastal Plain, hybrid bermudagrass sprigs can be planted Mar. 1 to Mar. 31. Cover sprigs 1" to 3"
deep (1.5" optimal). Sprigs should be planted quickly after digging and not allowed to dry in sun and
wind. For Coastal and Tifton 78 plant at least 10 b ac in 3' rows, spaced 2' to 3' in the row. Generally a
rate of 30 bu/ac is satisfactory to produce full groundcover in one or two years under good growing
conditions. Tifton 44 spreads slowly, so use at Ieot 40 bu/ac in 1.5' to 2' rows spaced 1' to 1.5' in row.
For broadcast/disked-in sprigs use about 60 bu/ac. Soil test for the amounts of lime, phosphorus,
potassium and micronutrients to apply preplant and for annual maintenance. Apply 60 to 100 lb/ac N in
the establishment year in split applications in Apri and July. For established stands apply 180 to 240
lb/ac N annually in split applications, usually in April and following the first and second hay cuts.
Reduce N rates by 25% for grazing. Refer to NCSU Technical Bulletin 305 Production and Utilization
of Pastures and Forages in North Carolina for more information or consult your regional agronomist or
extension agent for assistance. I
Z
---------------------------------•--------------------------------- ---------------------------------
------------------------------
761456 Database Version 4.1 Date Printed: 04-28-20I5 Crop Note Page 3 of 3

..y i,�Yi y S�': - c}, ,•__ 4. ._ _ "�.':'= ^'..'"' f-if ski z3.�^.- ice;'- F.'y- w+�;-'V�.l""r.:.....r: -� ���`S'•...,�!wl: � %w,L '`i�� i� �.• .`/_w... "'.fist. --�.�,��,
• %,:r v }': . - ..Y r,' ,s W � a«:�`'t 1, '' 7Y"' {"+4�--a �ti�'•` .t. at.: • rv�. ,�,,.� Q�,!1. x'�'�. ,:'�"'� � .a,y!�r•�' �:. �" �. (n ��
�''",�-- � -�;.. _ , i $ � : ` "Y, r -3 •`±�,'�4, fl trZ:." a '�' ' � �.;} :�'-dr:. 'y���a.r`� .,,41: {;'`
� .L ry, v ; r1 � •, ti� ;�) �y„ fr, FX '� }3 .x br• '�7[. i! '�'- i"3+ n Y +��•. '` k�+ �: } {�
sc^E-�"*ri- c4.- }Cry., y,+ � � 'c_6 ��r :.5--�-'r yy L',}�S�'�' �"a.,i.�r�yw'F �'•C''- �'sS' "°'i�^. ..«�'�. ,:i.+�; :^:,���eM1iS s�� +_ 'r.xw;l4t' � ��,
j- w. t��-'„g ..t, �r•'n, wI� :1 ; •rY .'a.�,, ;i" -, �Y { .?"s} S w, ��R' '�; ., a';Ynf( 'jl *'{ �" ;1; : y= e,. �n:'rt r5 �•'".k„�• y•-•. ,�.{ Il
-•t,}5',,'4�' Ck 3 si. ,1t,f - .( 6r,,,, t ��, K' tl,,, 'd g",. �•-s , :3" S t 3s"- : • rW, .: g[:�P;i7f7�• ,. y ..r.r,�,. �, s:# -'F"f` i 1 . 4•, tr;. .►� L
�, Y %r - �r ';.{ Y ' � � r,ar r::" '"� •�+ a-t,•.xrW.� , - Rhea. S"'WC`�`i:`r ,ia t t ,iS i 'jr•., .r i(e i •,Jf t' �• . t! + :3.�,^'� � i ;-'!',k, �^ s,�'S'r '�jx.!. t:, �+
+ s +4 H ` r^ r .,,o- ..�:'�:'n',r.,�," ., r c ,y..F .a ,� � -. JS:��, ^'?li, A r�.. F �, �s � ryi ii �r�-,;,$ �.r'yy�•.•. 3
'�i,',. �.,-'..t'• -S ! �:� t' .•,. r ti,•x�.�r! a"Yi,t� ±�!i � r>S' ."ra�r,'i's �Shc1 t i"'%;f+]�r �+ �'.Zs, {°h�. �f4yl.r�,: s•,::+.•,',7 -s sli�j;l:v?.y, r'.-:'.+j;
'•r .,;'p4,'' "li! � 'is.. ' rT« ,u a : t: ✓ •�i : l >ti la: 7 ^rt �= it +,� �� r.,f,y ,• . �L +.ats c.',..•: .y. ,..,N R$`� � .� i ,.� ems.., .. f. 3'�: da." ;k4s �-•
wu 3: �]+ C !+"Yl;' '" :.; �rr4;=, r •. +:.��. �,,. �, .5, 'x:.-•�': L., ..yf t' � i.� i aS - ;.�°,i' '�""^� ��", • 1�'
't ,qF 7, ! t T. �..5 _•Fi •t 'r2r �..Y t. %�:; rt�hy, .d.`�: ..c•..:; 2r '� wN fy t itw �,,,�ta'= + •�•� s:F -q-
�tt',4�lv .xr ?-e'_�:ti .43�.,u;r r• •1+.t�•s�•-�.{' ' t'0r� f:xr4`?5�,'S 7L��;0 �:Y,i< r• ??, : '.h"L_t-...
r w' :, ; �^ c=.• ,r_ .�_ -.r l - ye - .R +tip: :Grh ?.{�;�";j,,w::'c: r,� .ra,.y.. :.�'2�^e •r,�,. �.. .t: :ae..,.,, , :L :,,.f;. r:rrh. q[yr'r �.-t2. 'T:w �:.r-'•,
.f • -'r , ••v ';f- ?t•':r9 x, N•s, :dy r« s �,...: as(`aR •�j^}-1' 4r. 'tr,.:T•rG"% sa '+. }�•r• • .F _,.r, i+,:7$,, r•.,;S.L�If.�:
.ti y.,w .; ,,. !" 1{;� :. .: ";,,;'�.�.:. (• ' w ,^7 k =s r., ^F ..�r:-r «;xfK" ?mot.. .4..;-_•.•- �'!�, s ��-•ls:t' c... ,s. ,.t•t:9,�r r .•.'��t��
7•t j,�C•�, •,tK A.•''' �'.�+ ;r? "t;c r•rr{•ti ir.lri. •ray' .r .};-' y., !}� '�v
(-.. "• C ar 'k; _ kr:. N.=--. - w ;:? i' '.sr _ c r . !r . r „ i�i �.-.d•'4 �,�pr i� ;• 7•, W
i4. '.y �.u., .1 ..�';'^ ` �'• ;4 _'r•t•' e, '. t. �'s. + �j.7'.. �v,, ,� T'?r.�{!• ''�y^ _ 'P�.r ;ly J �i'�,,` `'�2,+ F°��i::,.;lrr;; 'u. :F•s: „�.�j ,-s:7",: *;x� .: .�s: •r r^�',cr' '^[: �.}a? _s'k�•t V � •«- ,} f�(cj}." •�} ,t,, �; ,�;�.•'!i:F�,. �,r��'4r vY` .n x '.�sx+„�, 9 i, tipis"!
iG'•.Y� ..'"! 4trl : ;..z r:-�'' �`xrJ+ N:t�•. ,.�., �.rK, y'.r.r. ,) x i:•3y g., ;�"f.,.:F'y�t..' ' &. lift*.,, ,,��, LIF,A"7{d„� .�7 !�e'•;Lb..ysi"••• .; r`.,,,�:",..,,tn:�
ih;•Vi', 4 f � a t1 .fi.�'�,- irk. hr. !a � - 40. r.. ._y�r✓ a. .�,,. �-.'�r' r.,+,1 ,Lr-, v„J_ r
iA' _•,h "+� ,�� '�«^ rCp;l-rtl.'�,�rR.e '�.e/ � '.�'^r '$.�•..':r s; '�` ''7�.�,'�°•. s r� trh ..r..,t. ;3•k' � . Y ti `+"fir. ':rt+rr `r.,.
r *, Vf r k, K u
`<. 'r,-a: F�..rir ,=:M. i'' °e�:idr j'tys„ '�. prr; q,•:.f�r 1`j' ;�...a �'" �•F,. ;:'
.t .rro -3- �:.? .:;. ° .y+•= ,t '�•+ �C. I„'c'.. ) d`if µ, �'✓V r, rr%i:.•i.
" w.:,r.-.is•:!'.r _ s:" -t , t• 9N`- "S"•ir.,. •• �Yf •.;',:tT. �1 ,:''•� /Y1 . S... }r i,�ti, ;, .t.;•tr. •.-kq'.1'� : sfdd;��,,r ..1t,,�� ,;a:& ;:1,•^
Alt yS.�SX'i�� •4 ,�i-� `r .,,��,,� � � r! '„+�?its'•� ,xt'. ;t.F;• ui.• ';<�.:� �., .� +•.. ,�5• L� r � �f; 7? _ •vG•�sF t-'.j �t{F t..••"
{r. =Ji. r'r' '"'��'- a�iF ':s :/.-+,�.3•,�tx, -�;, U•'i\ ti"d a'i' ,yLyy�� •sE!r �" f ,."a-,. tt ':�:t'' r' iT,�ty�,r• - i'e, :�• + ��:.�;y..,� „rYe �+"..,
1 �,.aF ,.��,_,l yk,"5 � ,x-1 .s� is �:• ✓y•. � i`di'c :,7vsY _ rr .',:`{ (•�j�. .•�r,�{`y wit S
i 71' {'�• s +�� V - .� •-3�-+ �•:�.. +. r-•a K-" 3. 1, �.d J r - -f' a .1� '�`^ •� 3�•- u�' r =''f � P' �"_4w
+ 4:r i =: Yt., � yam} s v.. Y , h may}► �...>•.'�'KT._ .i f� :{c^� �(/�:�ri'trin ril �., :. i Fri. +� ` M7 Y' 1,:
ti?•,r
,'[•m�+ 'YF' <•%Ft"��l F;'-4j'.`,�y �•i..`� .11'•-. fJ. v: �,,��'.•Y"`_.�i FR,r•ir;.. l;t.'.v�••, �Y �. :
AS
.i. l�.r �"� *, y'., r w '"�..,� •'ir.?;.v. ,-.. 1 �� rx b z tt• e, .,t .i�.�;•Y, �,,, rtiFrw? ;••• '�":;
�. i a , y .,'a TUNE
�'�^�+ �Zr.� 7' 1 lfjtt.� ����`,i'f � '{e�� S,: � r.�` r�j t•s: +} St:� r,_:
'.,k. hF�!„''ry�.q-.r if , 2�1,4's �f .�r -ra >•.• t., tt•,> ' .hy ,�, ss-:,,�.s%ii.; ; ;&rE.iG:yv '', tia�. •,y •,.-r-h r ..t prK :Yr•+: 4. ^rY , 4. s r -+;Yt% .;..i ,x•'L •3 �h r�c}TIC ��w�+.s� t•' 3iK LT - !*
s.i
_ t 7 .fr �'•�.,."�� ,•aC' �Si �, �'2 'Y a ii71-�'€';' <t.. FShe'�a2 Yi+ 1-�'-:' 'r:'eF; -r �yj�.�j �-�� •� j�+:. hsy,,,,�a ''f�; 1,; ?,Ll`. � �e,�, fir`;��•p �; �, '!" i�,�iii,r,? T'^f � -.
- • ! 'I.� 1, ':t'`��, r �4`Y•�- +pF. :•::.tir::).: 7 H �i[ !'F''+a � f�. `�'r$,x�, �n12k:-' y.� +'3j,�"dt n'�(f'31: V �.��i•T'��,',,-• �r t+'�r�ey;T•�'�.:`^t,-"+p��'r��S'#�{�l.'d'�.�' _r
V :r�i� I ki'�:Y ); " '`r• 4. - H +i �.. ~� f °•g't�',:�•� � - �y'r'T rx �'•.F1�F',te+ �!!" �y���.n'� �k7°,y� 4 �^��Y.Fti'-^` ?'{` 3:��.1.,�-^_*^•� "Va v,k�s�'ar.c ' i r�. �y'j:•-}+ +'n':^`r
� } 1�• 3,� _ � �; �t:�et;'.- t j�•:i�r ,%:� '� • '.�' ���`'�,.���•,4,��•n, ,.r �•���i �•y,` ^,.7W�,� '�� �� • :1-`7�� �..li•'L`f. �•'�',+Y.a.4�,r ,Ylt•
�• " •`�-- - Y ' 1r �'{ .y�r • �-^V`;'�✓ 1\ .V�j3 L" 1.� A [h•i..�i,y� y�, fr9 i'if` .4•;A .• ��' �•,•-
i "t�Yy`.�:� •�P - s �i 'a"`w; `•••� ! i� L.y �'a it wz' -:n -s%r• :'Y'9"�;� ,+jv7'' :s�f' •`'"V"�a
�I �•' �+^ �f.*i.+A r.� f fi .. „sYa t`V •� r. 'a-:- #t' `!C,.it = r:[ ,s ,137 �C ' n, � +- ^� n .; n s �"ti-! •�tsy '� ,'rl�1F.iy;.' �•fy,.�a
•� •�' '.�+ 5,,�• �� j•�' !�1_S ,,.., r) !�i' +.cV .Nt;.t.'t�`>:�." r"�•iJ� � R � ,tt • +5. 1
�K��..�t, �' �� �•.� r'`r'AY•! '•:fiS�T#. 9'• �/. �'�.. � : ,,.'fit w� ,.f.a�
.� ,� �, it ^ w �' • .,>.. r � ��. E �' ` � `;z., . �� „3 �s . ;�,%,.�
rJ "1',i�•`'•'�.+sbd.�;. ; 4; ems, y?•rCYg1 w wc' rKrr•,�F- t �.:!' '..;r+�t. ��J'`i•''";„'�'^.
r•.,i + ::h-•'i. •YET '." r.'. rY�. +. �� tt- :rt' St 1�, 4 J' i, - i a' i�:�,. kT •kY� 1' .a•?
u-. u.F•+.. .x 2'gcii+9,sa.� „- r ? '} ^� r. L ��{.. .:.Y:rr_•, �..�.! ;s; ��}}]r. as :�J.•
qy, ` -F •,tL � `:.'•'1�c1°`s�'. c' f;c �` ,•. _,°,a.+' +ri, ✓��M ^•^ SY r•. ` +•,..7 /'t r l"l •L�-�v�3•r '3i•E} •-,fiIPN
',.`?6�'�:5: ,..:'+J_r'.s ��.�.5 `-, ,a • 1t;r a�>V.N;% t 'i. +' .e" T.>•' Z �s�: y r-' 3l� �='Ti ;". '�► i �. ,: ''� � '�t'.I�,� p�t1, .y" yy� 2i.`ir. ,•.. - r
,.- y ..1: 1:.sti•.. '? . r +C�_ L- , s..Sf• 71.':41.3:1 d:'V+-. SAs'h.t �. ��• _
'�• .o;`?:{� 1�-1''-: •� '•+s .� .y.''k•.'k€' Y �*���� {'':�` .r�- v. •u '-(. ar!(: ,�`-•-;;,�, V-. �. �yV'sa-. ,� .rear,{st':n. i,,;rjr,•- .•rr •
r,5• -' '���'.� ..Y� r �w7•?i'$.��("y4;' y'�SE.i�:c� f• •'C Y"r.��•>_�"r if .�,+r t� �F.���}:z' "�q
52��}t
"•v y� .� r�Ft � �'1�+'..-^V • � z � �x i L'�� .� !t �'e - a :+ �, K;+,e�Y�.,lt•+.. ,� G•ctt:��1 �i. ts�' '�� k�.�-r��'�,`r -{fr'rt � ,jy 1� r�t•
� ;i r%� ii•r- �_ �: •� , f". ,a•a•.•:zbt � F. 'x +�i �t, i.•i c`sc t• �i.. •+d'
• \�� t r.,,,4� �1, ,���'.•? r.t -:. :yYF�',, <.. rj iy cr � ii,.,+r•}:1 k xw;t� v��`S�"�j #y. ,r°,... •f•'s•�....+ �r7 'iri �.
.r :c• +, y� t Yd yw i��-,,lF •� r r L 'I Sw 't'•ci.L?�' •P T'w Via:.. ,rt d }flkjt . ti; y: "�*..cil••'- 'M1''i! , 7i�'. '
b�, !� .-K ,� '�y,, .,,...4. _ �rr� .d !•Hh +'• ,,�}p}�,. ", y•��y S Q. t f .71G.Y 7i r i f
-\ 7.�� s ��k�r,�Y�`�iM�'s��4 �4•i, �y^�',y'.�_t7_=3?: !X �� ;pn•��k, ��, ° t���.�a ��'* �."��, ~� ..� ��°{��_i,
�;N I,,.-,rr-0+ti�,,TM,,.;frtS'y'i •r•�. ,) - •'tis ` .�7,i'i 'r
?
. `i,t' ''i t - err r1.1•�i7' +�-,{yt,.'k• rr"
' \� 'S•t%�•r i• I r:}` � ''� �.�li�:?w�S�'k'L.� �r; ry/�,•,,,. II 'r}f%, � �` �,'+' � ru-•-'•<��'4 sti
�4}:., f.i�' f J � � J t, y �r r � �.� k, et �h., r-r �r��• � 7�,� F• �� F s
l� �'i• t��r-n••-•' *i .. l••5�•� � ,.(, { . '_��+1 d "� rF✓ •aj � �� �'^�n�.,,� � �C� i"!• V '�` j 3-yJ',% f'`^�+ �^'���f• -i W� �. ` -+� 1r�+��~" � .?� `, ��.,r"\�' "%� ;
1:4 �� :a►• ��•_ � _ 'S � ' •.,;: ;{�'>� ! 1 9 .�.1 � r#�'";'A��'�'•y � �. � �.z ub
r f'.r " , !_ . ✓ / ;' i! ti,r},jSr , 1 �' d ylt'r- r ,c "" 4 lr = sy� w��� S k,
�i .. ?' (J � 4�} t, i +F r t 34 , '"- s3+� t" ►y i ^y�:y.{ �y ,,r� / �y
i•- ,Aaf . f. i f� 4 M.�• /� �" �•••w 'I•IL'IC"•"` .iiti.r .r'1 Yr � � a � �' ��
.- r•V �, �� � .« / t�Is: tir:••.i*: a � •. _ 7s' r �tt:�c�`F-�, s`r � e/?fct.: T/� '" + 'tt; .� f.
9- i 4.d3:3'+:. • �•� „ ,ir / . �l r7 "�:' _' �"+t' _ �M'?y'�!�'�`
t -:�`13'�1.c, ;t ,�, •p'.e_+r{l},Vc'�vK�SI/p +(.l •l.f.,
:..� }' a-xp, • >,. Uf fFr,F�:�i"�.+�;�. e u �,st,• 1.Y.:+C�_•f.Z� ,L �] +.. ti.
t•_dr, v _ (•` � ss� .:�. 'cy,, '� }J- 4 ,,T .1+.s •,} r '�'t• '�,{?d ••c.r' -
!i`5i�i.''•'�r`\\ a•�! A" �j%{� o�.+�,Y. +/..:y.r>.:.�,+�'.Tyre s'r• �3e. .e.��,•F.. t `Sf.,. -� v .Csrt= �+. "•t,. 3w:' ,r fIY�: t7 :.r i� + i�-.i' r L't,. K .,,, w' .t• �. i"S' ' _..". •� -� t.r �" 'l^ 1 +1' 'Y t {lh.1`.�,
'`"� •'(lY{�r%j� tS;�\ \ '� ,�1' yy �, f rr � J,G,y 4<���E : '�� '-,:��i' �uP��' ;Y.�-Y�k,¢�-' �t"2'/' s�,,,;pc• `,!f"�•i.e i:�v` }ra e.�„�,�tsx� ,�• ,�t r .tt .4� T5- AN4
,,._�e�`; i� .if,5• •„�,�,.Ii
f;. . _ '" ,°tnv` ••V` A :wi�'a' r 97%-r' .'. .y ,L-4'i�. 7'!i; S_ rw(i _ Y•-.j.5tw.{•r r..•, u'•yi. -'7 •":/ ,{ �P••'
r�S/.i+ r; 'r �r"� j •j';J�/ 0's^� .. -. '2. {1`siti�.=��r'+`-d.;g'� F' :I" Pst' f ��:F4`+ ti •;\•_.. ir; +'"i'�' �5.• :"-.z
�,„ �.:,M�� :y 4i •y,j . } \� "�,, '� � a �5r r � r `t r N •r.,•r`F�s 3': N �e it i<, k.. -�: ` i c rt ,s... ti; �;.. a,-eV�,+�'�V• ,� r
sT ,�s'7�,1 r, 4-.'S;;�.w..��i�;) ,�� 1'Ce. f 'FBwS}-r'-ttns �•t r• �� ,i�i'�.
_ y�• � a: St�ys,
-� - •° �7 `' \ -r ,_! �:'�' :T _ter ! �"'�`; �' r'•r `rtr' :i � .v�,T "V�3:.� tiw±;# r y.�. fr� �,�T;C;� �,\ ,� }u`.,y \r� ',I�%� s+.r,'� ''S'!' �;�
'..,: °ant' : +\ "�J't3 :�r� .+�y �• - r`xi� ?!'y,Y.: �y�..t `:' .r,,,.i,•.��'y i��„�`•t, -':} k'yi•.. •, ,r,���. '��•k- ., i.rxy',.�lt.�in
::M ,}� + .. + '��_'•�:{G.r'�:,•'x, ,s'. s"•1• t /'3 r '�. � � V s,•,•• r Yt'=., _ sA rs
t r
c, r' r '�.,, .0 J {a r� •r y ;•z' ? . i v r!. �' ,r a' ' .�• c.`•i- .�' a, - r '\ . 1• I f +-,� r .'f' '
.att ,"s' '"'k ..�� } f •"}-.. f' G. "'F pk'.,• Y• .�_ :i� _ ,�,, a , �lprh, '� � �i,.
„x ^r{ 4.I"''rl rr 7..SJ .r R\ f � .,i ' r': �~1�ti • � " a�.r� , }' �U';� � � � • �• v r- .. • ���'• 7`"! c�'-'"�,4=,'. \\. � 4 .1�11t;L.x• ,... � j�
Yx • r ?5•a a .4: 4 �� �' � l'" S � as � o • +,,$ /. � rF=
,'£� r ..,° '':[�'' r'�i", "r � �} r 6 7;i � .,., Jr r'r<!�','., s.� r .,.� {-t, \rq�j'_ . y^+y� r' rH1�t*���,R h•s' ��•�\�ft''+
„d*4 :Rr'� .�, r .+ { r r t r r !�E'{ ?�'' �� }" a ' t u• .,-; rs - +iY;;
arte {�:' .�•^1 j.�7: 1§ e \y•j. ✓ x. '•,'r.'�}• ',q `'k n''!` i +,r'-
F. 4 trs.. r F: �cs ���_ ,, ,i -:•,�i c.i t� 4a`Y , ;:t pp+f;�� r ,r i- k,. , y i�S ,�'.•�.., �r. }j"�;ts r -Tii,� ;•; u$In��=' ar�':�;'�
R.
r .
,f ;sy t y 'YeJ '�'• r ,rrFF�.. `4i L. > `•a
°' " r F rt� �., y","n��,7 , "T; •F"`!,;' i�(� Woo, �3v' K .. � - ': �. • . }' 's •;_ t� t Y'�i'^ " r,,yrs r� �tifw��.� rYl i"Sy� v �'• •:.�i � tt � , �'r •tX`S••..
=1`Jtry r' Sn' + "!'- tx^".:i-,ilr.��'i? ' ';f; i''a. •' r :C':°7' _' , i t: 4- .ji;rv'FA.:1.'!,yy.r' '(t#, h•l'?'�,�5'�V i '.f, �{ br}7.�ir Yl
p�4 r� � .. C', t�'i•S x7 r• !A,':•�,�:. •5: '�s �; :Sn y.., 'i„' •
' .R:3s.•�5.,�'?�n,�'1}. �,.;r;'..3j;��;T�;'Cit�;t,. � t' _r s" �r,•�};'7••.�c :tt.�:r S•fc^t{?'�'� lri.•,.,�1, .�•_.�t;;��:j�g,�a' y. ''�' rt. .r '�,.
;4. .,...n,. ri, ri*t ',4r, ,r4 t,�,r Tla'q'� ;y. yp. w,.'4d• F, -, r;.,_.� �*-i'�-�"x : ••+-' !r •r, �Y'k+"`^�x' i.,. �.,,.✓i. d�I �..i,,-� ''��..•• is"'•w�-.
°• It3 d ui' ;i i
A.`.� '� i'.:.:tr S^�: ✓Fl--[A r y�, r$;s� �....,.r�r y . 'S - !F: r s � IJ ty F r,�° ,i pn?,� n l s .t a ,.t ; .. r n a .,Z ,/ r- { y e-a i:''�'� r i c;3,.s r •w.' 1.: w4 a�;. t.;L' •fit,,
�S, .?{=t {'C,{ A• s.r t+� i 't.' .,a,i"{ y ,.:"a}"iT^ ��S�. - Y,t7• 1rri k'' ;lf;�.G,Tj� r rr Sy„n'..r.., +y..,"r• rs,
y+ a1; ;i' h , 'y:"sj ` f N .,.a-_• �'�•',-� :T�,G- n r !}j!";�Sr`,. y:• r't 1� :.ti. ,''�h
.?:'a . N %"I' ..�.•tAl
,t i �.'•,, .$'' n'*5, w4 -.; w "4Y, 5y,` S'}tR;`n yfdC-• `•�i'
:l' y Fs r •• ' ,��� �",• -t <; ..��`.. I �&"i•' �-� t'.,.r ,c- \�, .'li'"c e t .";•,,�P:� S�'�iL•, ��:-: -'�� �711.'ttsY'`' �"�;[�'.•y� -ti
r�;. �r. � r!i' r ��'iFY L } �,# � i r-SR\�; ..+ � ��,r��4.,✓.� - !, i� }'; � } 5'. �+Kj 's+4 1 ..� ..�� f t � c{n wv� r,: �l .. �.
a. yt r<' f .� r s rK, 43' r, c c- i _ t.•' j.�,s. r... + I -�. 7t •2' i •'h .•.� � i?^:t'�•�_.
fir
i •s r }.7 __>a <.•f -i•r-9 Fla r'�. 1:11 .tf`�tY.,, a'r1•.'.e:l 1, tie;
y -:r t F•, Xwr „. b ,� h, t.: '? ' w 'a r " ♦ • y� .+, .,, � 3Ff _ .,.'e r r li' •y'' :r}
Ali
J- L �-GVy tisa .t�. r � � f N r "S- Gh t Y 4 -.•,+ 3 r..
e. "^`.� � w ••'1.s kl., � ksj +•;P+y'j,•-w.+ � �.r.1,'' '.tN { i�'.s;�_' z+dq� ,y^1it�- i��r�*.�4•'1,�, �:' ;�?��'i'i {:�ir..s��'f,s�'�t �'i '',�"�'.ratr' st1 cc; (� ;
• o '•.. !''=y- s• .y; •S `r„•,F �` a..'r+ry{l�:x 1 J:.•y `�..;•. •'r,•r; r'r?t, ,,r •:'t;Va {=''1�'. T•!''�. r"••i"�:`;'= s ; J f ,;c}} �t ;'.�bY+]G+.i +; pry ,.,,i" (� ,, _
11 rf r = rfl-L} 1 Q•5 ii•� qr i+n �Ogg;
e •7} �, '�. ." .,,t,. r `"`t r ,`!F :'}x_'• �(r,l�'•3f't :'+ pti•'�''"r•� s� '• i't. r
' �__ J r s •,�= i {�'' • 's F ', r1 � � � -h,,��� � 1�'r"' ' r r r � �' w •: A•'� � w -tn= .,i(� •, r �.
•'r �w t�4liyA; ` :�•j�. .. E^..;�.f+ i•�•,r.,{��+ r ii•- t�•f�a y�,r i.�I ✓•, �,•--,44 ifT .. t� i.. ,`,i'�,�,��fr. F'e•!••e �•y'{jM• t 1.J
' �•1 �..', � r ` � Y�;�«t. :r ; t `v fa�J x i � s a' ,^,/ � n".. +''�' �w,�r 7 � � rr �.; �: �J rr^]'� - � � c� rv,�3•S''�f . I'�.rW LI
_LW ' '-.A ..-.,:r. "1 •;..,{Y..,S.�.r._.' ',: _ - _-..,...... .............. _ ...�...,..�_....,..... ......:a'x ._.r. 1 _ .. .. r.�. .... �4. ..: 7.-7,... .• ___

EEILD # SPRINKLERMONEY WAGON ACRES
1 0160 - 7025 8.491
2 0208 - 100 GUN/HW 11.470
3 HONEY WAGON 1.120
4 HONEY WAGON 1.400
5 0208 - .100 GUN 1.031
TOTAL PULLS = 5 ITUTAL ACRES = 23.51
0160 - .214 ACRES EX., .147 ACRES IN.
0208 - .518 ACRES EX., .450 ACRES IN.
ACRES = WIDTH X LENGTH / 43,560
t
2
5
1 rfrt-
4,
3
lt:t
5z�
EXISTING HYDRANT LOCATIONS
o PROJECTED SETUP LOCATIONS
FLEXIBLE HOSE NN 70'
-�. HONEY WAGON
--- 10' BUFFER
TITLE: MCKAY FARMS
AGRIMENT SERVICES INC.
'"sn m""G c0Nsu'TAN7S FARMER: BILL MCKAY
P.Q. BOX 1096
HEULAVI=. NC 28510
[phone] BY. JONATHAN MILLER I CK. BY: GENO KENNEDY
DATE: 5-25-99 CODES: T-4224 FARM #:31-136
TMAM ass ti a�rra�x
SCALE: 1 =400' DRAWING #:1 OF 1

.curt-23-55 04:20 PM
.r ..�� Ar•Vi
910 992 7950 P.02
A Inc
Wednesday, May 26, 1999
Murphy Farms
Xmig 'Weaterbeek
Land and Nutricru Mari%nr
Technical Specialist
PO Box 759
Rosc Hill, NC 28458
Deus Kraig;
1: was good talking with you this morning. It is good co see you doing well_ We sxc
interested in renting our egtuprAenE and developing a fleet that is lkelpftl to you the
customer. I have arrNed at the pricing structure enclosed based on my lirnived
erpericace. if you have rlitestions or suggestiotu, I would like to diii(ws them ar your
Cenvef+ eme.
` We have always had u good reputarinn for dependability and fairness as well as
responsiveness. If you need help anytitne day, night, or weckend as will be there for
you at Murphy to safeguard your interest and preserve your prop ny is aAy way wr
c;n.
l look forward w seeing you aoon and working toget6r to solve problems.
Thank you,
Ronald Urauglion,
Vice 1'rr5i6rnt
sash 11MOnfy ROAD
DUMY.NC !es)+
BtQNIri :C)19)992i1D FAX. (9 te) 9r.-IVS0
P. 02

JUIA-23-99 04:21 PM
ACqInc
T,1nkgr (9.000 gallons approg,)
'r.-wk (without operator)
Tmuk (with operator)
"Turra&aror (wlrhout operator)
Terrag:coe (with operator)
Ba!/Cr 600QC; pull t"f
iractor to pull Balzer
'rxr,,vator (without operarnr)
Rental Prices.
9A.ao/a.y
50.00/day
(plw $13/nult)
60.00/hour
75.00/hour
400.00/hcur
20G.00/day
3B.00 /h�o�u�r
L
Excavator (wir6 nperator)
a3.W/hour
'Dozer • 560C (without operator)
6G.00/hour
Dorcr (with operator)
85.00/hour
NTl t Lagoor. Agitator
xno/day
NTH Lagoon Pump
O.4G/day
P.03
ale egz 7950 P.03
32:.002'•►Yek
3W-00/weak
(plus S.25/1r1i1m)
4so.W day
4,80.00/moath
3,80.00/march
5,300/m9nth
RenralA vrirhout operator . Custanner provides f+irl. oil, ytv%w, daily and wctkly
servi.c. ACC will proajde maintc"nce upkeep.
Rental, without operator are M applwabiv to buyout if c9minuously recited Reutaln
for ptriods of last than a wcA- will be at cithcr the D:Oy or hourly charges deprndiug
oil which is lower.
Tide prices we basic' on cunomer pickup at our 7wd in Mriview (ne-ar Duna, NC).
We aau deliver for a sraminal Fee depcudtrlg oa the piec:.
Tires • If tires are worn out ACC will rrplarr us part of our maintsn=c#. DamaSed
tire% will be at the custonur's expense.
ACC kecpi otir equipment in good Shape.
W%1Uit TKV AGAD
DUN-4, NC; 2A31a
PHONE [phone] rnx-is14 sov9sa
TOTrL P. a33

ANIMAL FACILITY ANNUAL CERTIFICATION FORM
Certificate of Coverage or Permit Number 31-136 County Duplin Year 2oo 3
Facility Name (as shown on Certificate of Coverage or Permit) Bill McKay Farm
Operator in Charge for this Facility William P. McKav Certification # 18108
Land application of animal waste as allowed by the above permit occurred during the past calendar year ® YES
NO. If NO, skip Part i and Part Il and proceed to the certification. Also, if animal waste was generated but not
land applied, please attach an explanation on how the animal waste was handled_
PartI : Facility Information:
1. Total number of application Fields ® or Pulls ❑ (please check the appropriate box) in the Certified Animal
Waste Management Plan (CAWMP): 5 Total Useable Acres approved in the CAWMP
2351
2. Total number of Fields ® or Pulls ❑ (please check the appropriate box) on which land application occurred
during the year: 3 Total Acres on which waste was applied 19.99
S. Total pounds of Plant Available Nitrogen (PAN) applied during the year for all application sites:
5066.93
4. Total pounds of Plant Available Nitrogen (PAN) allowed to be land applied annually by the CAWMP and the
permit:
8590.15
5. Estimated amount of total manure, litter and process wastewater sold or given to other persons and taken off
site during the year N/A tons ❑ or gallons ❑ (please check the appropriate box)
6. Annual average number of animals by type at this facility during the previous year:
Due to date of permit 4/24/03 will supply this information in Mav 04
7. Largest and smallest �number of animals by type at this facility at any one time during the previous year:
Largest V _
Smallest_
(These numbers are for informational purposes only since the only permit limit on the number of animals at the
facility is the annual average numbers)
8. Facility's Integrator if applicable: Murphv Browns LLC
Part IIPart Facility
IF THE ANSWER TO ANY STATEMENT BELOW IS "NO", PLEASE PROVIDE A WRITTEN
DESCRIPTION AS TO WHY THE FACILITY WAS NOT COMPLIANT, THE DATES OF ANY NON
COMPLIANCE, AND EXPLAIN CORRECTIVE ACTION TAKEN OR PROPOSED TO BE TAKEN TO
BRING THIS FACILITY BACK INTO COMPLIANCE.
1. Only animal waste generated at this facility was applied to the permitted sites �� ®Yes El No
the past calendar year. ��
MAt� � � 2044
AFACF 3-14-03 1 WAR c
Nos+

417..
t. The facility was operated in such a way that there was no direct runoff of waste from
® Yes ❑ No
the facility (including the houses, lagoons/storage ponds and the application sites) during
the past calendar year.
:3. There was no discharge of waste to surface water from this facility during the past
® Yes ❑ No
calendar year.
4. There was no freeboard violation in any lagoons or storage ponds at this facility during
® Yes ❑ No
the past calendar year.
5. There was no PAN application to any fields or crops at this facility greater than the
® Yes ❑ No
levels specified in this facility's CAWMP during the past calendar year.
6. All land application equipment was calibrated at least once during the past calendar year.
❑ Yes lg No
7. Sludge accumulation in all lagoons did not exceed the volume for which the lagoon N
❑ Yes ❑ No
was designed or reduce the lagoon's minimum treatment volume to less than the volume
for which the lagoon was designed. �
8. 'A copy of the Annual Sludge Survey Form for this facility is attached to this CertilicationAff�/V
❑ Yes ❑ No
9. Annual soils analysis were performed on each field receiving animal waste during the
® Yes ❑ No
past calendar year.
10. Soil pH was maintained as specified in the permit during the past calendar Year? ❑ Yes ® No
11.. All required monitoring and reporting was performed in accordance with the facility's ® Yes ❑ No
permit during the past calendar year.
12. All operations and maintenance requirements in the permit were complied with during ® Yes ❑ No
the past calendar year or, in the case of a deviation, prior authorization was received
from the Division of Water Quality.
is. Crops as specified in the CAWMP were maintained during the past calendar year on all ® Yes ❑ No
sites receiving animal waste and the crops grown were removed in accordance with
the facility's permit.
14. All buffer requirements as specified on the permit and the CAWMP for this facility were ® Yes ❑.No
maintained during each application of animal waste during the past calendar year.
"I certify under penalty of law that this document and all attachments were prepared under my direction or
supervision in accordance with a system designed to assure that qualified personnel properly gather and evaluate the
information submitted. Based on my inquiry of the person or persons who manage the system, or those persons
directly responsible for gathering the information, the information submitted is, to the best of my knowledge and
belief, true, accurate, and complete. I am aware that there are significant penalties for submitting false information,
including the possibility of fines and imprisonment for knowing violations."
Bill McKav
Perrnittee Name and Title (type or print)
r
2/1y04
Signature of Permittee Date
Signature of Operator in Charge
(if different from Permittee)
asweathe permits:'I#'should be noted that Technscal:A§sistance
}iowever`every.-attempt w�11 lie made to complyby/4/y4.
dc) n b y
AFACF 3-14-03 2
Date

ANIMAL FACILITY ANNUAL CERTIFICATION FORM
Certificate of Coverage or Permit Number
31-136
County Duvlin Year !Roo-3
Facility Name (as shown on Certificate of Coverage or Permit) Bill McKav Farm
Operator in Charge for this Facility
William P. McKav Certification # 18108
Land application of animal waste as allowed by the above permit occurred during the past calendar year ® YES
❑ NO. If NO, skip Part I and Part II and proceed to the certification. Also, if animal waste was generated but not
land applied, please attach an explanation on how the animal waste was handled.
Part_I - Facilijy Information:
1. Total number of application Fields ® or Pulls ❑ (please check the appropriate box) in the Certified Animal Waste
Management Plan (CAWMP): 5 Total Useable Acres approved in the CAWMP
23.51
2. Total number of Fields ® or Pulls ❑ (please check the appropriate box) on which land application occurred
during the year: 3 Total Acres on which waste was applied 19.99
s. Total pounds of Plant Available Nitrogen (PAN) applied during the year for all application sites: '
5066.93
4. Total pounds of Plant Available Nitrogen (PAN) allowed to be land applied annually by the CAWMP and the
permit: 8590.15
5. Estimated amount of total manure, litter and process wastewater sold or given to other persons and taken off
site during the year NIA tons © or gallons ❑ (please check the appropriate box)
6. Annual average number of animals by type at this facility during the previous year:
4/24/03 —4/5/04 ave animal head is 3370.80
7_ Largest and smallest number of animals by type at this facility at any one time during the previous year:
Largest
Smallest
(These numbers are for informational purposes only since the only permit limit on the number of animals at the
facility is the annual average numbers)
8. Facility's Integrator if applicable: Murvhv Browns LLC
Part II: Facility Status:
IF THE ANSNVER TO ANY STATEMENT BELOW IS "NO", PLEASE PROVIDE A WRITTEN
DESCRIPTION AS TO WHY THE FACILITY WAS NOT COMPLIANT, THE DATES OF ANY NON
COMPLIAINICE, AND EXPLAIN CORRECTIVE ACTION TAKEN OR PROPOSED TO BE TAKEN TO BRING
THIS FACILITY BACK INTO COMPLIANCE.
1. Only animal waste generated at this facility was applied to the permitted sites during ® Yes p No
the past calendar year.
AFACF 3-14-03 1

2. The facility was operated in such a way that there was no direct runoff of waste from
® Yes ❑ No
the facility (including the houses, lagoons/storage ponds and the application sites) during
the past calendar year.
S. There was no discharge of waste to surface water from this facility during the past
® Yes ❑ No
calendar year.
4. There was no freeboard violation in any lagoons or storage ponds at this facility during
® Yes ❑ No
the past calendar year.
5. There was no PAN application to any fields or crops at this facility greater than the
® Yes. ❑ No
levels specified in this facility's CAWVIP during the past calendar year.
6. All land application equipment was calibrated at least once during the past calendar year. N/A
❑ Yes ❑ No
7. Sludge accumulation in all lagoons did not exceed the volume for which the lagoon N/A
❑ Yes ❑ No
was designed or reduce the lagoon's minimum treatment volume to less than the volume
for which the lagoon was designed.
8. A copy of the Annual Sludge Survey Form for this facility is attached to this Certification. N/A
❑ Yes [] No
9. Annual soils analysis were performed on each field receiving animal waste during the
® Yes ❑ No
past calendar year.
10. Soil pH was maintained as specified in the permit during the past calendar Year?
❑ Yes ® No
11. All required monitoring and reporting was performed in accordance with the facility's
® Yes [I No
permit during the past calendar year.
12. All operations and maintenance requirements in the permit were complied with during
® Yes [] No
the past calendar year or, in the case of a deviation, prior authorization was received
from the Division of Water Quality.
13. Crops as specified in the CAWMP were maintained during the past calendar year on all
® Yes ❑ No
sites receiving animal waste and the crops grown were removed in accordance with
the facility's permit.
14. All buffer requirements as specified on the permit and the CAIVVMP for this facility were
® Yes ❑ No
maintained during each application of animal waste during the past calendar year.
"I certify under penalty of law that this document and all attachments were prepared under my direction or
supervision in accordance -vvith a system designed to assure that qualified personnel properly gather and evaluate the
information submitted. Based on my inquiry of the person or persons who manage the system, or those persons
directly responsible for gathering the information, the information submitted is, to the best of my knowledge and
belief, true, accurate, and complete. I am aware that there are significant penalties for submitting false information,
including the possibility of fines and imprisonment for knowing ,iolations."
Bill McKav
Permittee Name and Title (type or print)
Signature of Permittee
2/11/04
Date
Signature of Operator in Charge Date
if different from Permittee
Corrective.t tions
Our most recent soi test showed 1-field BM4 needs i_4 touris of lime: I will apply lame- this field
accordlingly.as weather permits:' It shotild be noied thii.TechntcK Assistance_ is_limlte_d -with the N_/_ A_
answered items,_however every attempt will be made to comply by'4/24/04;
AFACF 3-14-03
2

VIQ__6, sad
Revised April 20, 1999
JUSTIFICATION & DOCUMENTATION FOR MANDATORY WA DETERMINATION
Facility Number - Operation is flagged for a wettable
Farm Name: c acre determination due to failure of
On -Site Representative: I Part eligibilityitem(s) Ft F2 F3 F4
Inspector/Reviewer's Name: 4z
Date of site visit:
Date of most recent WUP: v3haklq
Annual farm PAN deficit:
pounds
y Operation not required to secure WA
determination at this time based on
exemption E1 E2 E3 E4
Operation pended for wettable acre
determination based on P1 P2 P3
Irrigation System(s) - circle #:(D hard -hose -traveler, ..2. center -pivot system; 3. linear -move system;
64 stationary sprinkler system wlpermanent pipe; 5. stationary sprinkler system w/portable pipe;
stationary gun system w/permanent pipe; 7. stationary gun system wlportable pipe
PART I. WA Determination Exemptions (Eligibility failure, Part 11, overrides Part I exemption.)
E1 Adequate irrigation design, including mapdepicting wettable acres, is complete
and signed by an I or PE.
E2 Adequate D, and D./D3 irrigation operating parameter sheets, including map
depicting wettable acres, is complete and signed by an I or PE.
E3 Adequate D, irrigation operating parameter sheet, including map depicting
wettable acres, is complete and signed by a WUP.
E4 75% rule exemption as verified in Part Ill. (NOTE:75 % exemption cannot be
applied to farms that fail the eligibility checklist in Part II. Complete eligibility
checklist, Part 11 - F1 F2 ,F3, before completing computational table in Part 111)_
PART 11.75% Rule. Eligibility Checklist and Documentation of WA Determination
Requirements. WA Determination required. because. operation fails one of the. eligibility
requirements listed below:
_ F1 Lack of :acreage --which Tesulted in iover�pplicationmf-vvastewater-(PAN) on:spray_
field(s) :accordingiofarm's-last- woyearszf--rrigation7ecords. _ -
F2 Unclear,-.-illegible,-.Or lack of information/map.
F3 Obvious --field -limitations .(numerous=ditches;faiiure:to:deductTequired
buffer/setback-acreage;-or25%--of Iota] =a creageidentified_in-CAWMP=.iridudes
small;-irregulady-shaped fields = fields:less-than 5 !acresfor travelers -or.less-than
2 acres for:stationa ry -sprinklers).
F4 WA determination required because CAWMP credits field(s)'s acreage -in excess
of 75% of the respective field's total acreage as noted in table in Part III.

Revised April 20, 1999
Facility Number
Part Ili. Field
by Field Determination of 75% Exemption Rule for WA Determination
TRACT
NUMBER
FIELD
NUMBER',2
TYPE OF
IRRIGATION
SYSTEM
TOTAL
ACRES
CAWMP
ACRES
FIELD
%
COMMENTS3
!
I
I
FIELD NUMBER' - hvdrant_ Dull-zoneor.Doint numbers may be used in glace of field numbers
denendina on CAWMP
and type of irrigation -system. If pulls, etc. cross more -than -one field, inspector/reviewer will have to combine fields to
calculate 75% field by field determination for exemption; otherwise operation will be subject to WA determination.
FIELD NUMBER' - must be clearly delineated on map.
COMMENTS' - back-up fields with CAWMP acreage -exceeding =75% of its total:acres and having received less .than 50%
of its annual PAN as'docurnented in the farm's previous -two years' (1997 & 1998) of irrigation -records, -cannot serve -as -the
sole basis -forrequiring a WA Determination.-up�elds-must,benoted in the -comment sectionand must be accessible
by irrigation system.
Part IV. Pending WA Determinations -
P1 Plan 1acks1ollowing-.information:
P2 Plan -revision may_satisfy75% rule based on adequate overall PAN deficit -and by
adjusting -all field..acreage-to-below 75% use rate
P3 Other (ie/in process of installing new irrigation system):

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
William McKay
Bill McKay Farm
1516 Guman Powell Road
Kenansville NC 28349
Dear William McKay:
I 11kT1:!W'A
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
December 30, 1999
Subject: Fertilizer Application Recordkeeping
Animal Waste Management System
Facility Number 31-136
Duplin County
This letter is being sent to clarify the recordkeeping requirement for Plant Available Nitrogen (PAN)
application on fields that are part of your Certified Animal Waste Management Plan.
In order to show that the agronomic loading rates for the crops being grown are not being exceeded, you
must keep records of all sources of nitrogen that are being added to these sites. This would include nitrogen
from all types of animal waste as well as municipal and industrial sludges/residuals, and commercial fertilizers.
Beginning January 1, 2000, all nitrogen sources applied to land receiving animal waste are required to
be kept on the appropriate recordkeeping forms (i.e. ERR], IRR2, DRY1, DRY2, DRY3, SLURI, SLUR2,
SLD1, and SLD2) and maintained in the facility records for review. The Division of Water Quality (DWQ)
compliance inspectors and Division of Soil and Water operation reviewers will review all recordkeeping during
routine inspections. Facilities not documenting all sources of nitrogen application will be subject to an
appropriate enforcement action.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Ms. Sonya Avant of the
DWQ staff at [phone] ext. 571.
Sincerely,
Kerr T. Stevens, Director
Division of Water Quality
cc: Wilmington Regional Office
Duplin County Soil and Water Conservation District
Facility File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman; Secretary
Kerr T. Stevens, Director
CERTIFIED MAIL
RETURN.RECEIPT REQUESTED
William McKay
Bill McKay Farm
1516 Guman Powell Road
Kenansville NC 28349
Dear William McKay:
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
December 8, 1999
Subject: Conditional Approval
Animal Waste Management System
Facility Number 31-136
Duplin County
Our records indicate that your facility was conditionally certified in order to fulfill the requirements of
completion of your Certified Animal Waste Management Plan Certification. This letter is to inform you of your
unresolved conditional approval status. Any facility receiving a conditional approval must notify Division of Water
Quality (DWQ) in writing within 15 days after the date that the work needed to resolve the conditional certification
has been completed. Any failure to notify DWQ as required, subjects the owner to an enforcement action. As of
December 7, 1999, we have -no record of any information from you, advising us of the status of your conditional
approval. Therefore, please fill out the attached form and have your technical specialist and landowner sign the form
in the appropriate areas.
The completed form must be submitted to this office on or before 45 days of receipt of this letter. Please be
advised that nothing in this letter should be taken as removing from you the responsibility or liability for failure to
provide DWQ with proper notification of your conditional certification status or possible failure to comply with the
requirement to develop and implement a certified animal waste management plan by December 31, 1997.
If you have any questions regarding this letter, please do not hesitate to contact me at [phone]
extension 571.
Sincerely,
U
Sonya L. Avant
Environmental Engineer
cc: Wilmington Regional Office
Duplin County Soil and Water Conservation District
Facility File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled110% post -consumer paper

AGRIMENT SERVICES INC
PO BOX 1096
BEULAVILLE, NC 28518
[phone] tel/fax
10/22/99
Mr. Dean Hunkele
Division of Water Quality
127 Cardinal Drive Ext.
Wilmington, NC 28405
Dear Mr. Hunkele,
This letter is to address the annual compliance review conducted for Bill Mckay((3.L 31 6
This facility was pended for a wettable acre determination. As you are aware we have
already begun the process of addressing the wetted acre rule for farms either pending or
flagged. Please review enclosed maps and wup completed for both farms and re-evaluate
their current wettable acre status. The wettable acres coincide with the waste plan and
should meet minimum criteria to exempt the facilities from their current wetted acre
status. Please call if you have any questions.
With Kind Regards,
Ronnie G. Kennedy Jr.
Technical Specialist
Agriment Services, Inc.
Cc Bill Mckay
Duplin SWCD

WASTE UTILIZATION PLAN Page 1
DATE 10/12/99 FN 31-136
Producer. BILL MCKAY
Address: 1516 Gurman Powell Road
Kenansville, NC 28349
Telephone: 910-29M396
Type Operation: FEEDER TO FINISH
Number of Animals: 3672
The waste from your animal facility must be land applied at a specified
rate to prevent pollution of surface and/or groundwater. The plant
nutrients in the animal waste should be used to reduce the amount of
commercial fertilizer required for the crops in the fields where waste
is to be applied. This waste utilization plan uses nitrogen as the
limiting nutrient. Waste should be analyzed before each application
cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner. Always
apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can
utilize. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and available
water holding capacities. Normally waste shall not be applied to land
eroding at greater than 5 tons per acre per year. With special pre-
cautions, waste may be applied to land eroding at up to 10 tons per
acre per year. Do not apply waste on saturated soils, when it is
raining, or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed under DWQ
regulations. Wind conditions should also be considered to avoid drift
and downwind odor problems. To maximize the value of the nutrients
for crop production and to reduce the potential for pollution, the
waste should be applied to a growing crop or applied to bare ground
not more than 30 days prior to planting. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
This plan is based on waste application through irrigation for this
is the manner in which you have chosen to apply your waste_ If you
choose to inject the waste in the future, you need to revise this
plan. Nutrient levels for injecting waste and irrigating waste are
not the same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage require-
ments should be based on the waste analysis report from your waste
management facility. Attached you will find information on proper
sampling techniques, preparation, and transfer of waste samples to
the lab for analysis.
This waste utilization plan, if carried out, meets the requirements
for compliance with 15A NCAC 2H.0217 adopted by the Environmental
Management Commission.

WASTE UTILIZATION PLAN
AMOUNT OF WASTE PRODUCED PER YEAR (GALLONS, FT3, TONS, ETC.)
3672 hogs x 1.9 tons waste/hogs/year = 6976.8 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
3672 hags x 2.3 PAN/hog*ear = 8445.6 lbs. PAN/year
Applying the above amount of waste is a big job. You should plan time
and have appropriate equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
TABLE 1: ACRES OWNED BY PRODUCER
Page 2
TRACT FIELD SOIL TYPE & CLASS- CROP YIELD LBS COMM " ' LBS
DETERMINING PHASE CODE AW N PER ACRES AW
4224 1(4)map
NOB
4224-1(4)map
NOB
4224 TB(5)map
NOB
4224-13(5)map NOB
4224 2(1)map
CRB
4224-2(1)map
CRB
4224 2(2)map
CRB
4224-2(2)map
CRB
4224 3(3)map
AUB
4224-3(3)map
AUB
PER AC AC USED
APPLIC.
TIME
BH
6.1
305
1.4
427
SG
1
100
1.4
140
BH
6.1
305
1.031
314A55
SG
1
100
1.031
103.1
BH
5.2
260
8.491
2207.66
SG
1
100
8.491
849.1
BH
5.2
260
11.47
2982.2
SG
1
100
11.47
1147
BH
5.5
275
1.12
308
SG
1
100
1.12
112
0
Total 8590.515
- Indicates that this field is being over seeded (i_e_ interplanted)
or winter annuals follow summer annuals.
NOTE: The applicator is cautioned that P and K may be over applied
while meeting the N requirements. Beginning in 1996 the Coastal Zone
Management Act will require farmers in some eastern counties of NC to
have a nutrient management plan that addresses all nutrients. This
plan only addresses Nitrogen.

WASTE UTILIZATION PLAN Page 3
TABLE 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate
land. See required specifications 2.)
TRACT FIELD SOIL TYPE & CLASS- CROP YIELD LBS COMM " L B S
DETERMINING PHASE CODE AW N PER ACRES AW
PER AC AC USED
0
0
0
0
0
0
0
Total 0
- Indicates that this field is being over seeded (i.e. interpianted)
or winter annuals follow summer annuals.
" Acreage figures may exceed total acreage in fields due to
over seeding.
` Ibs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and 2 above:
LBS N
APPLY
CROP CODE
CROP
UNITS PER UNIT
MONTH
BH
HYBRID BERMUDA GRASS -HAY
TONS
50
APR-AUG
C
CORN
BUSHELS
125
MAR-JUNE
SG
SMALL GRAIN OVER SEED
AC
50
SEPT-MAR
SA
SUMMER ANNUALS
AC
110
APR -MAY
WA
WINTER ANNUALS
AC
100
SEPT-APR
BC
HYBRID BERMUDA GRASS -CON GRAZED
TONS
50
APR-SEPT
BP
HYBRID BERMUDA GRASS -PASTURE
TONS
50
APR-SEPT
FC
TALL FESCUE -CON GRAZED
TONS
50
SEPT-APR
FH
TALL FESCUE -HAY
TONS
50
SEPT-APR
FP
TALL FESCUE -PASTURE
TONS
50
SEPT-APR
SB
SOY BEANS
BUSHELS
4
JUN-SEPT
DSB
DOUBLE CROP SOY BEANS
BUSHELS
4
JUN-SEPT
CO
COTTON
TONS
0.1
MAY-JUN
W
WHEAT
BUSHELS
2
OCT-MAR
"SEE NCSU MEMO'
`SEE NCSU MEMO"

WASTE UTILIZATION PLAN
Page 4
TOTALS FROM TABLES 1 AND 2
ACRES LBS AW N USED
TABLE 1 8590.515
TABLE 2 0 0
TOTAL 0 8590.515
AMOUNT OF N PRODUCED 8445.6
— BALANCE-144.915
" This number must be less than or equal to 0 in orderto
fully utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffers, fitter strips along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than
the acres shown in the tables.
NOTE: The Waste Utifization Plan must contain provisions for periodic
land application of sludge at agronomic rates. The sludge will be
nutrient rich and will require precautionary measures to prevent
over application of nutrients or other elements. Your production
facility will produce approximately IWI •//. y pounds of plant
available nitrogen (PAN) per year in the sludge that will need to be
removed on a periodic basis. This figure is PAN when broadcasting
the sludge equipment, may be needed when you remove this sludge.
See attached map showing the fields to be used for the utilization of
waste water.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of
the soil at the time of irrigation such that runoff or ponding occurs.
This rate is limited by initial soil moisture content, soil structure,
soil texture, water droplet size, and organic solids. The application
amount should not exceed the available water holding capacity of the
soil at the time of irrigation nor should the plant available nitrogen
applied exceed the nitrogen needs of the crop.
Your facility is designed for 180 days of temporary storage
and the temporary storage must be removed on the average of once every
6 months. In no instance should the volume of waste being stored in
your structure be within -),7 feet of the top of the dike.

WASTE UTILIZATION PLAN Page 5
If surface irrigation is the method of land application forthis plan, it
it is the responsibility of the producer and irrigation desigm signer to
ensure that an irrigation system is installed to properly irrigate the
acres shown in Tables 1 and 2_ Failure to apply the recommended rates
and amounts of Nitrogen shown in the tables may make this plan invalid
Call your Agriment Services representative for assistance in determining
the amount of waste per acre and the proper application rate
prior to beginning the application of your waste.
NARRATIVE OF OPERATION: SEE ATTACHMENT

REUSED ADDENDUNI TO WASTE UTILIZA TION PLAN.
FACILITY NUMBER 31-136
FARM NAME: BILL MCKA Y FARM
OWNER NAME: BILL MCKA Y
DESIGN CAPACITY: 3672 FEEDER TO FINISH
THIS WASTE PLAN IS A REVISION OF THE 12/13/95 PLAN COMPLETED BY
TECH SPECIALIST JOHNNY L. LANIER. THIS PLAN REPRESENTS THE ACRES
AS DEPICTED BY THE WETTABLE ACRE DETERMINATION.
LAGOON HAS ENOUGH STORAGE FOR 135 DAYS THE CROPS OF COASTAL
HAY WITH SMALL GRAIN OVERSEED WILL ALLOW PUMPING EVERY 135
DAYS.
ALL SOILS IN THIS PLAN HAVE AN INSTANTANEOUS LOADING OF .5 IN/HR
NOT TO EXCEED 1.0 IN/PER EVENT.
NO WASTE SHOULD BE APPLIED TO A CROP THAT DOES NOT HAVE A
REALISTIC YIELD FOR THE USAGE OF IRRIGATED SWINE WASTE EXCEPT
FOR PREPLANT. ALL FIELDS MUST MEET MONITORING AND REPORTING
REQUIREMENTS WHEN USED. MR. MCKAY PLANS TO APPLY SWINE WASTE
IN ACCORDANCE WITH HIS SPECIFIC WASTE ANALYSIS NOT TO EXCEED
THE HYDRAULIC LOADING OF THE SOILS. MR MCKAY MAY USE CATTLE
TO REMOVE SMALL GRAIN IN WINTER MONTHS.
10/12/99
PDXWMEGNEDY JR
TECHNICAL SPECIALIST
&W;i( jc`
)e P4�4�, �"IAI
BILL MCKAY
OWNER/OPERATOR
cLscA/
."fe-a
14S

WASTE UTILIZATION PLAN
Plans and Specifications
1. Animal waste shall not reach surface waters of the state by runoff,
drift, manmade conveyances, direct application, or direct discharge
during operation or land application. Any discharge of waste which
reaches surface water is prohibited. Illegal discharges are subject
to assessment of civil penalties of $10,000 per day by the Division
of Water Quality for every day the discharge continues.
2. The Local NRCS office must have documentation in the design folder that
the producer either owns or has long term access to adequate land
to properly dispose of waste. If the producer does not own adequate
land to properly dispose of waste, he shall provide NRCS with a copy
of a written agreement with a landowner who is within a reasonable
proximity, allowing him/her the use of the land for waste application
for the life expectancy of the production facility. It is the
responsibility of the owner of the facility to secure an updated Waste
Utilization Plan when there is a change in the operation, increase in
the number of animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen
needs for realistic crop yields based on soil type, available moisture,
historical data, climate conditions, and level of management, unless
there are regulations that restrict the rate of application for other
nutrients.
Animal waste may be applied to land that has a Resource Management
System (RMS) or an Alternative Conservation System (ACS). If an ACS
is used the soil loss shall be no greater than 10 tons per acre per
year and appropriate filter strips will be used where runoff leaves
the field. These fitter strips will be in addition to "Buffers"
required by DEM. (See FOTG Standard 393-Filter Strips and Standard
390 Interim Riparian Forest Buffers).
5. Odors can be reduced by injecting the waste or disking after waste
application. Waste should not be applied when the wind is blowing.
6. When animal waste is to be applied on acres subject to flooding, it
will be soil incorporated on conventionally tiled cropland. When
applied to conservation tilled crops or grassland, the waste may be
broadcast provided the application does not occur during a season
prone to flooding. (See "Weather and Climate in North Carolina" in
the NRCS Technical Reference - Environment file for guidance.
7. Liquid waste shall be applied at rates not to exceed the soil infil-
tration rate such that runoff does not occur off -site or to surface
water; and in a method which does not cause drift from the site during
application. No ponding should occur in order to control conditions
conducive to odor or flies and to provide uniformity of application.
B. Animal waste shall not be applied to saturated soils, during rainfall
event, or when the surface is frozen.
9. Animal waste shall be appiied on actively growing crops in such a
manner that the crop is not covered with waste to a depth that would
inhibit growth. The potential for saft damage from animal waste should
also be considered.
Page 6

WASTE UTILIZATION PLAN
Page 7
10. Waste nutrients shall not be applied in fall or winter for spring
Planted crops on soils with a high potential for leaching. Waste
nutrient loading rates on these soils should be held to a minimum
and a suitable winter cover crop planted to take up released
nutrients. Waste shall not be applied more than 30 days prior to
Planting of a crop on bare soil.
11. Animal waste shall not be applied closer than 25 feet to surface
water. This distance may be reduced for waters that are not perennial
provided adequate vegetative filter strips are present (See standard
393 - Filter Strips)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings
other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and
public right -of ways.
15. Animal waste shall not be discharged into surface waters, drainage ways,
or wetlands by discharge or by over -spraying- Animal waste may be
applied to prior converted wetlands provided they have been
approved as a land application site by a "technical specialist".
Animal waste should not be applied on grassed waterways that discharge
into water courses, except when applied at agronomic rates and the
application causes no runoff or drift from the site.
16. Domestic and industrial waste from wash down facilities, showers,
toilets, sinks, etc., shall not be discharged into the animal waste
management system.
17. Lagoons and other uncovered waste containment structures must maintain
a maximum operating level to provide adequate storage for a 25-year,
24-hour storm event in addition to one (1) foot mandatory freeboard.
18. A protective cover of appropriate vegetation will be established on
all disturbed areas (lagoon embankments, berms, pipe runs, etc.).
If needed, special vegetation shall be provided for these areas and
and shall be fenced, as necessary to protect the vegetation.
Vegetation such as trees, shrubs, and other woody species, etc. are
limited to areas where considered appropriate. Lagoon areas should be
kept mowed and accessible. Lagoon berms and structures should be
inspected regularly for evidence of erosion, leakage or discharge.
19. if animal production at the facility is to be suspended or terminated,
the owner is responsible for obtaining and implementing a "closure
plan" which will eliminate the possibility of an illegal discharge,
pollution and erosion.
20. Waste handling structures, piping, pumps, reels, etc., should be
inspected on a regular basis to prevent breakdowns, leaks, and spills.
A regular maintenance checklist should be kept on site_

WASTE UTILIZATION PLAN
Page 8
21. Animal waste can be used in a rotation that includes vegetables and
other crops for direct human consumption. However, if animal waste
is used on crops for direct human consumption it should only be applied
pre plant with no further applications of animal waste during the crop
season.
22. Highly visible markers shall be installed to mark the top and bottom
elevations of the temporary storage (pumping volume) of all waste
treatment lagoons. Pumping shall be managed to maintain the liquid
level between the markers. A marker will be required to mark the
maximum storage volume for waste storage ponds.
23. Waste shall be tested within sixty days of utilization and soil shall
be tested at least annually at crop sites where waste products are
applied. Nitrogen shall be the rate - determining element Zinc
and copper levels in the soils shall be monitored and alternative crop
sites shall be used when these metals approach excessive levels. pH
and waste analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three years. Waste
application records for all other waste shall be maintained for five
years.
24. Dead animals will be disposed of in a manner that meets North
Carolina State regulations or other States' regulations.

WASTE UTILIZATION PPfLA�N/ Page 9
NAME OF FARM:
OWNER / MANAGER AGREEMENT
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above.
I (we) know that an expansion to the existing design capacity of
the waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
Division of Water Quality (DWQ) before the new animals
are stocked. I (we) also understand that there be no discharge
of animal waste from this system to surface waters of the state
from a storm event less severe than the 25 year, 24 hour storm.
The approved plan will be filed on -site at the farm office and at
the office of the local Soil and Water Conservation District and
will be available for review by DWQ upon request.
1(we) understand that I must own or have access to equipment,
primarily irrigation equipment, to land apply the animal waste
described in this waste utilization plan. This equipment must be
available at the appropriate pumping time such that no discharge
occurs from the lagoon in a 25-year 1-day storm event. I also
certify that the waste will be applied on the land according to
this plan at the appropriate times and at rate that no runoff
occurs.
NAME OF FACILI OWNER: L MCKAY
SIGNATURE: / ATE:
NAME OF MANAGER (if different from owner):
SIGNATURE: DATE:
NAME OF TECHNICAL SPECIALIST: RONNIE G. KENNEDY JR_
AFFILIATION: Agriment Services Inc.
PO Box 1096
Beulaville 518
SIGNATURE: DATE: !o/a

JUN-23-99 04:20 PM
.. --.r +r•`w
Wednesday. May 26,1999
Murphy Farms
hnig Weuerbeek
Land and Nutrient Man%rr
Technical Specialist
PU Box 759
Ro3e Hill, NC 28458
Feat Kraig.
P.02
910 692. 7950 P.02
0
1: A as good tacking with you this morning. It is good w see you doing well. Wt arc
interested in renting our egwpment and developing a Beer thaE is lselpful to you the
customer. I have arrived at the Pricing strucwre enclosed based nn my limited
experience. If you have questions o: suggcstio► s, I would lilw w diiicwhs Chem at your
convenience.
We have always had c, good reputatinn for dependability and fairness as well as
responsiveness. If you need help anytitne day, night, or weekend we will be there for
you zt Murphy to safeguard your interest and prtserve your properny in any way wr
can.
I look forward to seeirg you soon and working together to solve problems.
Th/ mk you,
f,
Ronald Uraughon,
Vice President
5656I7M0THY ROAD
DUNK, NC 313)4
Phs.INE: (71C)192.3I V FAX. (9 it) M 700

Lr.J
JUN-23-99 04:21 PM
ACC Inc
Rental Prices
--
01r. Wk (without npera,or)
i'rLwk (with operator)
4Terragmr (wr=hout operator)
T errAgaoc (with opaggor)
Bauer MG pull typt
Tractor to pull Balzer
` Exe-avator (without operarm l
Excavator (arirh operttur)
'Dozer - S30G (without operator)
Duscr (with opentor)
NTL i Lagoot :agitator
NTH Lagoon Pump
50.00/dav
(plus $.23/mdc)
60.0G/hour
75.00/hour
100.00/hour
200.00/play
38.00 /hour
G5.00/hour
85. Acttr
6C.00/hou r
85.00/hour
30.Wday
45.0C/day
P.03
310 0.2 7950 P,@3
0
3W.0or+�eek
(plus s.2S/mil*)
4S0.0C/day
4,800.00/month
3.60.00/maath
5W-00/ds}• cir
S'"O/mgnth
Xenrals without operator . Custoater pruvides hirl, ag, g,+r4w, daily and Wcokly
servi.e. ACC will provide maintecance upkeep.
Renal, without operator are 7'i'16 applicable to buyout if continuously rented lkent-A6
for periods of lass than a Wes► will be at either the Uaily or Dourly charge3 upending
all which is lower.
Theo prices we ba"d on customer pick-up at our yard in Mmview (near Doan, NC),
We can delive► for a t,ominal fez depending oa the piect.
Tires • If tires are worn out ACC will replan- to part of our Maiatln=Ce. Damaged
tires will be at the customer's txpenst.
ACC keeps our equipment in good shape.
sloe Thi0TW ROAD
Di. N4, NC 3334
PHOW (9nq 612-1337 rAx- (flZI 192•79b0
TOTAL P.0

North Caroina State Umenly is a hnl-
7" Lie venay red a owd luarg ntution
Of The urnoraty of North carolm
DeparWwnt of Crop science
Memorandum
TO: North Carolina Certified T nical Specia ists
FROM: Dr. Jim Green, Chairman
NC State University Forage roduction Workgroup
DATE: June 29, 1998
T/
SUBJECT: Crop Management Practices for Select Forages
Used in Waste Management
College of Agricunurs and Lfe Sciarices
Campw Box 7620
aele4gh, NC 27595.7620
019.515.2647
019.515.7969 (fax)
The following is a four -page summary of suggestions for management practices for some
forage crops that can be used in waste management plans. These suggestions are a result of
discussions within the NC State University Forage Production Workgroup, a group comprised
of NC State faculty and NRCS agency personnel with expertise with the crops.
There are limited documented research responses of some of these practices on the many soils
and environments where these crops are currently being grown. The Forage Production
Workgroup has taken the available data and used the combined experiences and realistic
estimates of key people to come up with suggestions that will allow farmers to incorporate
these crops and practices into waste management plans. As data become available to
substantiate or refute these suggestions, the Forage Production Workgroup will make
appropriate changes.
Bermuda Overseeded With Cereal Rye and Annual Ryegrrrss
Currently two types of `5ryegrass" are being used for winter overseeding in fields used for
animal waste management. Cereal eve is a winter annual smallgrain that looks similar to
wheat, barley and oats. Annual ryegrms is a winter annual grass that looks touch like tall
fescue. Both of these grasses, when growing during the winter on bermuda sod, can have
significant impact on subsequent bermuda yields. In effect, the total yields from an acre
growing the combination of bermuda with these winter annuals will usually yield between 1-2
tons more per acre than bermuda growing alone for the year. Therefore, the total amount of
PAN /acre for the year is about lop lbs more than for bermuda alone. Although cereal rye and
annual ryegrass are suitable crops for overseeding, the management of the crops are different
and thus practices implemented are dependent on the crop selected.

No* Car*m Stain Urrwniy 4 a land- Depertrnent of Crop S Aence
W urrventy and a ooMtuwl reunion
of The Uwaso d North Caroina
• Coleys of Apricuiture anC Uto Sooncoe
Campus Box 7620
Raleigh, NC 276957820
919.5152047
919.515.7969 (fax)
Cereal Rye
The cereal rye should be planted by October 15 to provide the best opportunity to get winter
growth. The most consistent stands are obtained from drilling rye into short (less than 3
inches tall) bermudagrass sod. If drilling is not possible, the seeds may be broadcast on short
bermuda sod followed by a light cultivation with a disc or tillage implement. The seeding rate
for broadcast planting of seeds should be 1.5 times the rate for drilled seeds. The last
application of animal waste is to be applied to the bermuda prior to August 31. An
application of 50 lbs/acre of Plant Available N (PAN) may be applied between September 15
and October 30. An additional 50 lbs/acre of PAN may be applied in February -March. If rye
growth is harvested on time and does not significantly shade the bermuda, PAN rates for the
subsequent bermuda crop are based on realistic yields of bermuda. A harvest is required prior
to heading or April 7, which ever cogs first. This is necessary to minimize the potential for
shading bermuda and reducing its yields. The PAN rate for grazed systems with bermuda
overseeded with cereal rye must be reduced in accordance with NRCS Technical
Standard #590.
Annual Ryegrass
Annual ryegrass should be planted by October 15 to provide the best opportunity to get winter
growth. The most consistent stands are obtained from drilling ryegrass into short (less than 3
inches tall) bermudagrass sod. If drilling is not possible, the seeds may be broadcast on short
bermuda sod followed by a light cultivation with a disc or tillage implement. The seeding rate
for broadcast planting of seeds should be 1.5 times the rate for drilled seeds. The last
application of animal waste is to be applied to the bermuda prior to August 31. An
application of 50 lbs/acre of (PAN) may be applied between September 15 and October 30.
An additional 50 lbs/acre of PAN may be applied in February -March. If additional PAN is
applied to the ryegrass in April -May, the PAN rate for the bermuda must be reduced by a
corresponding amount. This is necessary because ryegrass growth during Apri!-May will
reduce bermuda yields and shorten the time bermuda can fully utilize the N. A harvest is
required by heading or April 7, which ever comes first to prevent shading of emerging
bermuda during April -May period. To favor the production of the bermuda, additional
harvests of ryegrass will be required when the ryegrass canopy reaches 12 to 15 inches height.
The PAN rate for grazed systems with bermuda overseeded with annual ryegrass must be
reduced in accordance with NRCS Technical Standard #590.

FEILD
# SPRINKLERMONEY WAGON
ACRES
1
0160 -
7025
8.491
2
0208 --
100 GUN/HW
11.470
3
HONEY
WAGON
1.120
4
HONEY
WAGON
1.400
5
0208
- 100 GUN
1.031
TOTAL
PULLS =
5 ITOTAL ACRES = 23.51
0160 -
.214 ACRES EX., .147 ACRES IN.
0208 -
.518 ACRES EX., .450 ACRES IN.
ACRES
= WIDTH
X LENGTH / 43,560
1� 2
I
I
I
i
I
1
4 'iiiii��" M A
I I ` 14V� .1 .� 7 fly q�
Iylw 3
I
iA 1II1
III%
• EXISTING HYDRANT LOCATIONS
o PROJECTED SETUP LOCATIONS -
FLEXIBLE HOSE 70'
-----HONEY WAGON
----- 10' BUFFER
TITLE: MCKAY FARMS
AGRIMENT SERVICES INC.
Y 'm' CONSULTANTS FARMER: BILL MCKAY
P.O. BOX 1096
BE , 2a519
(252) BY: JONATHAN MILLER CK. BY GENO KENNEDY
s2} 5sa-2-284e
IMAM ,CiO:SM79MMALM111
DATE: 5-25-99 1CODES: -42241 FARM #:31---136
SCALE: 1"=400' DRAWING #:1 OF 1

4g
4", grit N,
ail" hew
ran
A
a 4�
W-A
CC
11 01
""saw,
rc
_J1fp
it, ft
A
_71
J.
W jQ6
—Ivy al in 00%,
1—.:

Irrigated Acmap Mu niinatioo Procedures
For Waamater Application Equipemcat
STATIONARY SPRINKLER SYSTEM
FIELD DATA WORKSHEET *
1. Sprinkler make and model number _ SINNIGER 7025
2. Sprinkler nozzle size #22 NOZZLE - MAROON 11/32" [inch]
3. Lateral spacing 8fl [feet] by sprinkler spacing along lateral 80 [feet]
4. Operating pressure at the sprinkler 65 [psi]
5. Sprinkler wetted diameter 160 [feet] YES measured or NO determined from chart.
6. Number of sprinklers operating at one time 3
7. Total number of sprinklers or sprinkler locations in the system
Exterior sprinklers:
Interior sprinklers:
28
full circle fl part circle
17
HI circle
Sprinkler locations permanently marked: YES yes NO no
8. Supply line YES Permanent pipe NO Portable pipe
9. "Lateral line size [inch]. If there is more than one size, indicate the size
and approximate length of each. Can be done on the map.
10. **Lateral Iine length
[feet] (Longest lateral)
11. **Supply line length [inch]. If there is more than one size, indicate the size
and approximate length of each. Can be done on the map.
I2. **Supply line length [feet]. Maximum pumping distance.
13. **Pump make and model number
14. **Pump capacity
15. **Engine make and model number
16. **Electric motor horsepower and rpm
[gpm]
,or
[hp] [rpm]
Note: It is strongly recommended that you field measure the sprinkler wetted diameter. You should
do this on the longest lateral about half -way down the lateral.
*Locate each sprinkler or sprinklers location on the map. Indicate whether it is full circle or part
circle. Show the location of the supply line. Irrigated acres are determined by line, zone, and field.
**Optional data, furnish where possible.
***Only the person or people collecting the data should sign the Field Data Worksheet.
*** information furnished by
and/or//� _.W� WZ
X$ifViature of owner or facirity represolylive Signature of tedinigeWecialist
BILL MCKAY
Printed name of owner or facility representative
and/or RONNIE G. KENNEDY, JR.
Printed name of technical specialist
Date Date

f_Jt ti A LfiAY
STATIONARY SPRINKLER
IRRIGATION SYSTEM
STATIONARY GUN SYSTEM
FIELD DATA WORKSHEET *
1.
Gun make and model number /ad
`sf,/�/��
2.
Gun nozzle size r%/ [inch],
ring orifice, taper bore orifice
3.
Lateral spacing 115—
[feet] by gun spacing along lateral /`�� _ [feet]
4.
Operating pressure at the gun
66 [psi]
5.
Gun wetted diameter Qwlel ]feet].
/ measured or determined from gun chart
6.
Number of guns operating at one time
I
7
Total number of guns or gun locations in the system 522 /
Exterior guns: is __
full circle part circle
Interior guns: (a
full circle
Gun locations permanently marked:
yes no
8.
Supply line /VO
Permanent pipe ePortable pipe
••9.
Lateral line size [inch]. If there is
more than one size, indicate the size and approximate length of
each. Can be done on the map.
"10.
Lateral line length
[feet]. (Longest lateral)
"11.
Supply line size [inch]. If there is
more than one size, indicate the size and approximate length of
each. Can be done on the map.
"12.
Supply line length
[feet]. Maximum pumping distance.
*'13.
Pump make and model number
"14.
Pump capacity
[gpm]
"15.
Engine make and model number _ _
_ _ _ _ , or
'*16.
Electric motor horsepower and rpm
[hp] [rpm]
Note: It is strongly recommended that you field measure the gun wetted diameter. It should be done on the
longest lateral about half -way down the lateral.
Locate each gun or gun location on the map. Indicate whether it is full circle or part circle. Show the location of
the supply line. Irrigated acres are determined by lateral line, by zone, or by field.
Optional data, furnish where possible
' Information furnishe y
and/or
A-Rna re of owner or facili r resentat" Signalure of tec//h,,Vp,,-,1Iist
Printed name of owner or facility representative Printed name of technical specialist
Date
Date
•" Only the person or people collecting the data should sign the Field Data Worksheet.
15

N(, k,4 K
Irrigated Acreage Determination Procedures
for Wastewater Application Equipment
STATIONARY SPRINKLER-ZG SYSTEM
WETTABLE ACRE COMPUTATIONAL WORKSHEET
1. Farm number (identification) I 13 (a Field number (identification)
2. Irrigation system designation Existing irrigation system
New/expanded irrigation system
3. Number of stationary sprinklers # interior sprinklers �` # Exterior sprinklers
4. Wetted diameter "2d 8 Ifeet] from Field Data Worksheet
S. Spacing 141' r /O-I Sprinkler spacing along lateral [feet]
70 Z Sprinkler spacing as a percentage of wetted diameter
6. Sprinkler pattern Multiple laterals Single lateral
Excessively spaced sprinklers
7. Read the irrigated area per sprinkler for the given wetted diameter from the appropriate table and
column based on pattern, spacing, and sprinkler location.
Acres per interior sprinkler from
. -5,09 Acres per exterior sprinkler from
Table - Column
Table Column C
B. Multiply the tabulated irrigated acreage value per sprinkler by the number of sprinklers of each
category in the field. Add all of these. The surn is the total irrigated acreage for the field.
(a) Acres per interior sprinkler X -" # Sprinklers — Acres
r 14? (b) Acres per exterior sprinkler X -2 # Sprinklers 436 Acres
a2& Total wettable acres for field (Sum: 8a + 8b)
-; Wettable Acre Computational Worksheet completed by:;: _' ' .� ;1`^ __ Date:?�
Sign Life of tech'`swcialist
9

t_.`& ML<ICF'
Irrigated Acreage Determination Procedures
for Wastewater Application Equipment
STATIONARY SPRINKLE/GUN, YSTEM
WETTABLE ACRE COMPUTATIONAL WORKSHEET
1. Farm number (identification)
2. Irrigation system designation
a. Number of stationary sprinklers
4. Wetted diameter
- I3 Field number (identification) oZ
I
av £s
Existing irrigation system
New/expanded irrigation system
# Interior sprinklers �� # Exterior sprinklers
(feet) from Field Data Worksheet
5. Spacing / 'Y3 )r/2�57 Sprinkler spacing along lateral ]feet]
70,Z Sprinkler spacing as a percentage of wetted diameter
6. Sprinkler pattern Multiple laterals Single lateral
Excessively spaced sprinklers
7. Read the irrigated area per sprinkler for the given wetted diameter from the appropriate table and
column based on pattern, spacing, and sprinkler location.
U Acres per interior sprinkler from
,-S/5Acres per exterior sprinkler from
Table S Column J?
Table S Column C
g. Multiply the tabulated irrigated acreage value per sprinkler by the number of sprinklers of each
category in the field. Add all of these. The sum is the total irrigated acreage for the field.
-'/�U(a) Acres per interior sprinkler X !�z_ # Sprinklers = a Acres
• 51U (b) Acres per exterior sprinkler X &5" # Sprinklers =9, 99 Acres
Total wettable acres for field (Sum: 8a + 8b)
r
Wettable Acre Computational Worksheet completed by: Date: 9
Signal rc f tech nict9 specialist
9

Z;4 ­_ nit #C. is IA l
Irrigated Acreage Determination Procedures
for Wastewater Application Equipment
STATIONA Y SPRINKLER / UN SYSTEM
WETTABLE ACRE -COMPUTATIONAL WORKSFiEET
I. Farm number (identification)
Field number (identification)
2. Irrigation system designation
✓
Existing irrigation system
New/expanded irrigation system
.i. Number of stationary sprinklers / 7 # Interior sprinklers aU # Exterior sprinklers
4. Netted diameter / 6 0 [feet] from Field Data Worksheet
S. Spacing e..F E0 Sprinkler spacing along lateral [feet]
.5,0 2:, Sprinkler spacing as a percentage of wetted diameter
b. Sprinkler pattern ✓ Multiple laterals Single lateral
Excessively spaced sprinklers
7. Read the irrigated area per sprinkler for the given wetted diameter from the appropriate table and
column based on pattern, spacing, and sprinkler location.
Z1/9Acres per interior sprinkler from
�GyrY Acres per exterior sprinkler from
Table Column
'fable Column C
8. Multiply the tabulated irrigated acreage value per sprinkler by the number of sprinklers of each
category in the field. Add all of these. The sum is the total irrigated acreage for the field..
� /y9(a) Acres per interior sprinkler X % # Sprinklers = off, �97 Acres
d1_1_1 (b) Acres per exterior sprinkler X O)8 # Sprinklers = 91;0' Acres
6 76 / Total wettable acres for field (Sum: 8a + 8b)
Wettable Acre Computational Worksheet completed by: .. Date: /--:z-
Signajuie'of techni 1 dalist
(!
�6

le
Tf-
�.� DYJCER 'CER�'IF'I A.Ti I N F' :x�GAT`YON- �UIPMENT -.,..
r. *r . , _ .�.. .. • :.... .. , ..---...- - ---- ...
.
-- - --
certify that I. own, have access to) the.
;:
`:. (Producer)
irrigation equipment::
- ;.
.'following
TYPE IRRIGATION AND SIZE 07w 6ti
AVAILABLE FROMC
:Y
_
I further certify that, through the arrangements I have made concerning irrigation equipment. [
•`_
will be able to irrigate as necessary accordin o my waste management plan.
-
Signature Date
{pro er)44,
:i.
.'y
'k.

WASTE UTILIZATION PLAN Page 1
DATE 10/12/99 FN 31-136
Producer: BILL MCKAY
-- Address: 1516 Gurman Powell Road
Kenansvdie, NC 28349
Telephone: 910-29"396
Type Operation: FEEDER TO FINISH
Number of Animals: 3672
The waste from your animal facility must be land applied at a specified
rate to prevent pollution of surface and/or groundwater. The plant
nutrients in the animal waste should be used to reduce the amount of
commercial fertilizer required for the crops in the fields where waste
is to be applied. This waste utilization plan uses nitrogen as the
limiting nutrient Waste should be analyzed before each application
cycle_ Annual sod tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner. Always
apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can
utilize. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and available
water holding capacities. Normally waste shall not be applied to land
eroding at greater than 5 tons per acre per year. With special pre-
cautions, waste may be applied to land eroding at up to 10 tons per
acre per year. Do not apply waste on saturated soils, when it is
raining, or when the surface is frozen. Either of these conditions R1 ECI' 1VIF'n
may result in runoff to surface waters which is not allowed under DWQ
regulations. Wind conditions should also be considered to avoid drift
and downwind odor problems. To maximize the value of the nutrients A P R 0 6 Z009
for crop production and to reduce the potential for pollution, the
waste should be applied to a growing crop or applied to bare groundj�;
not more than 30 days prior to planting. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
This plan is based on waste application through irrigation for this
is the manner in which you have chosen to apply your waste. If you
choose to inject the waste in the future, you need to revise this
plan. Nutrient levels for injecting waste and irrigating waste are
not the same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage require-
ments should be based on the waste analysis report from your waste
management facility. Attached you will find information on proper
sampling techniques, preparation, and transfer of waste samples to
the lab for analysis.
This waste utilization plan, if carried out, meets the requirements
for compliance with 15A NCAC 2H.0217 adopted by the Environmental
Management Commission.
RECEIVED I DENR I DWD
AQU1FFR-PPnTFC.TI0N SECTION
MAR 312009

WASTE UTILIZATION PLAN
AMOUNT OF WASTE PRODUCED PER YEAR (GALLONS, FT3, TONS, ETC.)
3672 hogs x 1.9 tons waste/hogs"ar = 6976.8 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
3672 hogs x � 2.3 PAN/hog*ear = B445.6 lbs. PAN/year
Applying the above amount of waste is a big job. You should plan time
and have appropriate equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
TABLE 1: ACRES OWNED BY PRODUCER
Page 2
TRACT FIELD SOIL TYPE 8 CLASS- CROP _YIELD_VIELD LBS COMM " ' LBS
DETERMINING PHASE CODE AW N PER ACRES AW
PER AC AC USED
4224 1(4)map
NOB
4224--1(4)map
NOB
4224 1B(5)map
NOB
4224-1B(5)map NOB
4224 2(1)map
CRB
4224 2(1)map `CRB
4224 2(2)map
CRB
4224 2(2)map
CRB
4224 3(3)map
AUB
4224-3(3)map
AUB
APPLIC.
TIME
BH
6.1
305
1.4
427
SG
1
100
1.4
140
BH
6.1
305
1.031
314.455
SG
1
100
1.031
103.1
BH
5.2
260
8.491
2207.66
SG
1
100
8.491
849.1
BH
5.2
260
11.47
2982.2
SG
1
100
11.47
1147
BH
5.5
275
1.12
308
SG
1
100
1.12
112
0
Total 8590.515
- Indicates that this field is being over seeded (i.e. interplanted)
or winter annuals follow summer annuals.
NOTE: The applicator is cautioned that P and K may be over applied
while meeting the N requirements. Beginning in 1996 the Coastal Zone
Management Act will require farmers in some eastern counties of NC to
have a nutrient management plan that addresses all nutrients. This
plan only addresses Nitrogen.

WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only I operator does not own adequate
land. See required specifications 2.)
TRACT FIELD
Page 3
SOIL TYPE & CLASS- CROP YIELD LBS COMM * LBS
DETERMINING PHASE CODE AW N PER ACRES AW
PER AC AC USED
0
0
0
0
0
0
Total 0
Indicates that this field is being over seeded (i.e. interplanted)
or winter annuals follow summer annuals.
* Acreage figures may exceed total acreage in fields due to
over seeding.
ibs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crap codes used in tables 1 and 2 above:
LBS N
APPLY
CROP CODE
CROP
UNITS PER
UNIT
MONTH
BH
HYBRID BERMUDA GRASS -HAY
TONS
50
APR-AUG
C
CORN
BUSHELS
1.25
MAR -.TUNE
SG
SMALL GRAIN OVER SEED
AC
50
SEPT-MAR
SA
SUMMER ANNUALS
AC
110
APR -MAY
WA
WINTER ANNUALS
AC
100
SEPT-APR
BC
HYBRID BERMUDA GRASS -CON GRAZED
TONS
50
APR-SEPT
BP
HYBRID BERMUDA GRASS -PASTURE
TONS
50
APR-SEPT
FC
TALL FESCUE -CON GRAZED
TONS
50
SEPT-APR
FH
TALL FESCUE -HAY
TONS
50
SEPT-APR
FP
TALL FESCUE -PASTURE
TONS
50
SEPT-APR
SB
SOY BEANS
BUSHELS
4
JUN-SEPT
DSS
DOUBLE CROP SOY BEANS
BUSHELS
4
JUN-SEPT
CO
COTTON
TONS
0.1
MAY- JUN
W
WHEAT
BUSHELS
2
OCT-MAR
*SEE NCSU MEMO*
*SEE NCSU MEMO*

WASTE UTILIZATION PLAN
Page 4
TOTALS FROM TABLES 1 AND 2
ACRES LBS AW N USED
TABLE 1 .Z & • 5 1 8590.515
TABLE 2
TOTAL " • -61 8590.515
AMOUNT OF N PRODUCED 8445.6
' BALANCE-14a.915
" This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffers, filter strips along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than
the acres shown in the tables.
NOTE: The Waste Utilization Plan must contain provisions for periodic
Land application of sludge at agronomic rates. The sludge will be
nutrient rich and will require precautionary measures to prevent
over application of nutrients or other elements. Your production
facility will produce approximately QSj,,6 t/ pounds of plant
available nitrogen (PAN) per year in the sludge that will need to be
removed on a periodic basis. This figure is PAN when broadcasting
the sludge equipment, may be needed when you remove this sludge.
See attached map showing the fields to be used for the util nation of
waste water.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of
the soil at the time of irrrgation such that runoff or ponding occurs.
This rate is limited by initial sod moisture content, soil structure,
soil texture, water droplet size, and organic solids. The application
amount should not exceed the available water holding capacity of the
soil at the time of irrigation nor should the plant available nitrogen
applied exceed the nitrogen needs of the crop.
Your facility is designed for 180 days of temporary storage
and the temporary storage must be removed on the average of once every
6 months. In no instance should the volume of waste being stored in
your structure be within -t,7 feet of the top of the dike.

WASTE UTILIZATION PLAN
Page 5
If surface irrigation is the method of land application for this plan, it
It is the responsibility of the producer and irrigation design, signer to
ensure that an irrigation system is installed to property irrigate the
acres shown in Tables 1 and 2. Failure to apply the recommended rates
and amounts of Nitrogen shown in the tables may make this plan invalid
Call your Agriment Services representative for assistance in determining
the amount of waste per acre and the proper application rate
prior to beginning the application of your waste.
NARRATIVE OF OPERATION: SEE ATTACHMENT

REVISED ADDENDUM TO WASTE UTILIZATION PLAN.
FACILITY NUMBER 31-136
FARM NAME: BILL MCKAY FARM
OWNER NAME: BILL MCKA Y
DESIGN CAPACITY: 3672 FEEDER TO FINISH
THIS WASTE PLAN IS A REVISION OF THE 12/13/95 PLAN COMPLETED BY
TECH SPECIALIST JOHNNY L. LANIER. THIS PLAN REPRESENTS THE ACRES
AS DEPICTED BY THE WETTABLE ACRE DETERNIINATION.
LAGOON HAS ENOUGH STORAGE FOR 135 DAYS THE CROPS OF COASTAL
HAY WITH SMALL GRAIN OVERSEED WILL ALLOW PUMPING EVERY 135
DAYS.
ALL SOILS IN THIS PLAN HAVE AN INSTANTANEOUS LOADING OF .5 IN/HR
NOT TO EXCEED 1.0 IN/PER EVENT.
NO WASTE SHOULD BE APPLIED TO A CROP THAT DOES NOT HAVE A
REALISTIC YIELD FOR THE USAGE OF IRRIGATED SWINE WASTE EXCEPT
FOR PREPLANT. ALL FIELDS MUST MEET MONITORING AND REPORTING
REQUIREMENTS WHEN USED. MR MCKAY PLANS TO APPLY SWINE WASTE
IN ACCORDANCE WITH HIS SPECIFIC WASTE ANALYSIS NOT TO EXCEED
THE HYDRAULIC LOADING OF THE SOILS. MR MCKAY MAY USE CATTLE
TO REMOVE SMALL GRAIN IN WINTER MONTHS.
10/12/99
PONNIEGNEDY JR
TECHNICAL SPECIALIST
10/12/99
BILL MCKAY
OWNER/OPERATOR
f jb-% tom' I f 1. Kfc� o., /�c,�s Z 31 1/
o •� 4,t-G r-,Lf '

WASTE UTIL17ATION PLAN
Plans and Specifications
Page B
1. Animal waste shag not reach su rface waters of the state by runoff,
drift, manmade conveyances, direct appfication, or direct discharge
during operation or land application. Any discharge of waste which
reaches surface water is prohibited. lgegal discharges are subject
to assessment of civil penalties of $10,000 per day by the Division
of Water Quality for every day the discharge continues.
The Local NRCS office must have documentation in the design folder that
the producer either owns or has long term access to adequate land
to properly dispose of waste. If the producer does not own adequate
land to properly dispose of waste, he shall provide NRCS with a copy
of a written agreement with a landowner who is within a reasonable
proximity, allowing him/her the use of the land for waste application
for the life expectancy of the production facility. It is the
responsibility of the owner of the facility to secure an updated Waste
Utilization Plan when there is a change in the operation, increase in
the number of animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen
needs for realistic crop yields based on soil type, available moisture,
historical data, dimate conditions, and level of management, unless
there are regulations that restrict the rate of application for other
nutrients.
4. Animal waste may be applied to land that has a Resource Management
System (RMS) or an Aitemative Conservation System (ACS). If an ACS
is used the soil loss shall be no greater than 10 tons per acre per
year and appropriate filter strips wig be used where runoff leaves
the field. These filter strips wig be in addition to "Buffers"
required by DEM. (See FOTG Standard 393-Filter Strips and Standard
390 Interim Riparian Forest Buffers).
5. Odors can be reduced by injecting the waste or disking after waste
appbcation. Waste should not be applied when the wind is blowing.
B. When animal waste is to be applied on acres subject to flooding, it
will be soil incorporated on conventionally titled cropland. When
applied to conservation oiled crops or grassland, the waste may be
broadcast provided the application does not occur during a season
prone to flooding. (See "Weather and Climate in North Carolina" in
the NRCS Technical Reference - Environment file for guidance.
7. Liquid waste shall be applied at rates not to exceed the soil infil-
tration rate such that runoff does not occur off -site or to surface
waters and in a method which does not cause drift from the site during
application. No ponding should occur in order to control conditions
conducive to odor or flies and to provide uniformity of application.
8. Animal waste shall not be applied to saturated soils, during rainfall
event, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a
manner that the crop is not covered with waste to a depth that would
inhibit growth. The potential for salt damage from animal waste should
also be considered.

WASTE UTILIZATION PLAN
Page 7
10_' Waste nutrients shall not be applied in fall or winter for spring
planted crops on soils with a high potential for leaching. Waste
nutrient loading rates on these soils should be held to a minimum
and a suitable winter cover crop planted to take up released
nutrients. Waste shall not be applied more than 30 days prior to
planting of a crop on bare soil.
11. Animal waste shall not be applied closer than 25 feet to surface
water. This distance may be reduced for waters that are not perennial
provided adequate vegetative fitter strips are present (See standard
393 - Filter Strips)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings
other than those owned by the landowner.
14. Waste shag be applied in a manner not to reach other property and
public right -of ways.
15. Animal waste shall not be discharged into surface waters, drainage ways,
or wetlands by discharge or by over -spraying. Animal waste may be
applied to prior converted wetlands provided they have been
approved as a land application site by a "technical specialist".
Animal waste should not be applied on grassed waterways that discharge
into water courses, except when applied at agronomic rates and the
application causes no runoff or drift from the site.
16. Domestic and industrial waste from wash down facilities, showers,
toilets, sinks, etc., shall not be discharged into the animal waste
management system.
17. Lagoons and other uncovered waste containment structures must maintain
a maximum operating level to provide adequate storage for a 25-year,
24-hour storm event in addition to one (1) foot mandatory freeboard.
1 B. A protective cover of appropriate vegetation will be established on
all disturbed areas (lagoon embankments, berms, pipe runs, etc.).
If needed, special vegetation shall be provided for these areas and
and shall be fenced, as necessary to protect the vegetation.
Vegetation such as trees, shrubs, and other woody species, etc. are
limited to areas where considered appropriate. Lagoon areas should be
kept mowed and accessible. Lagoon berms and structures should be
inspected regularly for evidence of erosion, leakage or discharge.
19. If animal production at the facility is to be suspended or terminated,
the owner is responsible for obtaining and implementing a "closure
plan' which will eliminate the possibility of an illegal discharge,
pollution and erosion.
20. Waste handling structures, piping, pumps, reels, etc., should be
inspected on a regular basis to prevent breakdowns, leaks, and spills.
A regular maintenance checklist should be kept on site.

WASTE UTILIZATION PLAN
Page 8
21. Animal waste can be used in a rotation that includes vegetables and
other crops for direct human consumption. However, if animal waste
is used on crops for direct human consumption it should only be applied
pre plant with no further applications of animal waste during the crop
season.
22_ Highly visible marker; shag be installed to marls the top and bottom
elevations of the temporary storage (pumping volume) of all waste
treatment lagoons. Pumping shall be managed to maintain the liquid
level between the markers. A marker will be required to mark the
maximum storage volume for waste storage ponds.
23. Waste shall be tested within sixty days of utflizaation and soil shall
be tested at least annually at crop sites where waste products are
applied. Nitrogen shall be the rate - determining element Zinc
and copper levels in the soils shall be monitored and alternative crop
sites shall be used when these metals approach excessive levels. pH
and waste analysis records shag be kept for five years. Poultry dry .
waste application records shall be maintained for three years. Waste
application records for all other waste shall be maintained for five
years.
24. Dead animals will be disposed of in a manner that meets North
Carolina State regulations or other States' regulations.

r
WASTE UTILIZATION PLAN Page 9
NAME OF FARM: _�� )
OWNER / MANAGER AGREEMENT
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above.
I (we) know that an expansion to the existing design capacity of
the waste treatment and storage system or construction of new
facipties will require a new certification to be submitted to the
Division of Water Quality (DWQ) before the new animals
are stocked. I (we) also understand that there be no discharge
of animal waste from this system to surface waters of the state
from a storm event less severe than the 25 year, 24 hour storm.
The approved plan will be filed on -site at the farm office and at
the office of the local Soil and Water Conservation District and
will be available for review by DWQ upon request.
I (we) understand that 1 must own or have access to equipment,
primarily irrigation equipment, to land apply the animal waste
described in this waste utilization plan. This equipment must be
available at the appropriate pumping time such that no discharge
occurs from the lagoon in a 25-year 1-day storm event I also
certify that the waste will be applied on the land according to
this plan at the appropriate times and at rate that no runoff
occurs.
NAME OF FACIL OWNER: L MCKAY,.
SIGNATURE: ATE: a
NAME OF MANAGER (if different from owner):
SIGNATURE: DATE:
NAME OF TECHNICAL_ SPECIALIST: RONNIE G. KENNEDY JR.
AFFILIATION: Agriment Services Inc.
PO Box 1096
Beulaville8
SIGNATURE: DATE: ����'

Revised April 20, 1999
JUSTIFICATION & DOCUMENTATION FOR MANDATORY WA DETERMINATION
Facility Number 3, - t Operation is flagged for a wettable
Farm Name: acre determination due to failure of
On -Site Representative: Si Part 11 eligibility item(s) Ft F2 F3 1-4
InspectorlReviewer's Name:
Date of site visit: g-64 — n
Date of most recent WU P:
Annual farm PAN deficit: pounds.
Operation not required to secure WA
determination at this time based on
exemption E9 E2 E3 E4
Operation pended for wettable acre
determination based on P1 P2 P3
Irrigation System(s) - circle #: 1. hard -hose traveler; _2. center -pivot system; 3. linear -move system;-
(:]�)stationary sprinkler system w/permanent pipe; 5. stationary sprinkler system w/portable pipe;
( stationary gun system w/permanent pipe; 7. stationary gun system w/portable pipe a
PART I. WA Determination Exemptions (Eligibility failure, Part II, overrides Part I exemption.)
E1 Adequate irrigation design, including map depicting wettable acres, is complete
and signed by an I or PE.
E2 Adequate D, and D203 irrigation operating parameter sheets, including map
depicting wettable acres, is complete and signed by an"'I or PE.
E3 Adequate D, irrigation operating parameter sheet, including map depicting
wettable acres, is complete and signed by a WUP.
E4 75% rule exemption as verified in Part Ill. (NOTE-75 % exemption cannot be
applied to farms that fail the eligibility checklist in Part II. Complete eligibility
checklist, Part 11- F1 F2 F3, before completing computational table in Part II1).
PART 11. 75% Rule.Eligibiiity Checklist and. Documentation of WA Determination
Requirements. WA Determination .required .because_operation fails one of the. eligibility _ -
requirements listedhelow:
F1 Lack of acreage_whichTesultedinmverm. pplicationmfwastewater,(PAN) onz pray.
field(s) accord ingfolarm'sdast-two yearsnfIn igation-Teconds.-.
_ F2 Unclear, -.illegible, -or lack of information/map.
F3 0bvious-field -limitations -(numerousAitches;failure:-io:deductlequired
_
bufferlsetbackzcreage;-or25%-nfIota I acreageidentifieddri CAWJVIRJnbIudes -_
small; irregularly -shaped .fields = fields-less#han-5acresfor. travelers-or.lessthan
2 acres for.-stationarysprinklers).
F4 WA determination required because CAWMP credits feld(s)'s acreage -in excess
of 75% of the respective field's total acreage as noted in table in Part Ill.

Revised April 20, 1999
Facility Number -
Part 111. Field
by Field Determination
of 75% Exemption Rule for WA Determination -
TRACT
NUMBER
FIELD
NUMBER',2
TYPE OF
IRRIGATION
SYSTEM
TOTAL
ACRES
CAWMP
ACRES
FIELD
%
COMMENTS'
�
C
FIELD NUMBER' - hydrant, pull, zone, or.point numbers may be used in place of field numbers depending on CAWMP
and type of irrigation system. - If pulls, etc. cross more -than one field, inspector/reviewer will have to combine fields to
calculate 75% field by field determination for exemption; otherwise operation will be subject to WA determination.
FIELD NUMBER' - must be clearly delineated on reap.
COMMENTS' - back-up fields with CAWMP acreage-exceeding75% of its total:acres and having received less than 50%
of its annual PAN as documented in the farm's previous -two years' (t 997 & 1998) of.irrigation-records,--cannot serve -as -the
sole basis for requiring a WA Determ_ination:=Back-up fields - must•benoted in the -comment -section.-and must be accessible
by irrigation system.
Part IV. Pending WA Determinations -
Pi Plan:#acks_following-information:
P2 Plan -revision may:satisfy75% rule based on adequate overall PAN deficit and by
adjusting all field acreage#o below 75% use rate
P3 Other (ielin process of installing new irrigation system):

State of North Carolina
Department of Environment
and Natural Resources RECEIVED
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston, Howard, Jr., P.E.,
William McKay
Bill McKay Farm
1516 Guinan Powell Rd
Kenansville NC 28349
Dear William McKay:
JUL 22 1998
BY:
Director
1••
NCDENR
NORTH CAROUNA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
July 13, 1998
Subject: Certificate of Coverage No. AWS310136
Bill McKay Farm
Swine Waste Collection, Treatment,
Storage and Application System
Duplin County
In accordance with your application received on June 24, 1998, we are forwarding this Certificate
of Coverage (COC) issued to William McKay, authorizing the operation of the subject animal waste
collection, treatment, storage and land application system in accordance with General Permit
AWG100000. This approval shall consist of the operation of this system including, but not limited to,
the management of animal waste from the Bill McKay Farm, located in Duplin County, with an animal
capacity of no greater than 3672 Feeder to Finish and the application to land as specified in the Certified
Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations
as specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to actual
increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the -General
Permit or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS -
143-215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This
request shall be made within 30 days of notification by the Division.
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Certificate of Coverage AWS310136.-
Bill McKay Farm
Page 2
This COC is not automatically transferable. A name/bwnership change application must be
submitted to the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the
right to apply for an individual non -discharge permit by contacting the engineer listed below for
information on this process. Unless such a request is made within 30 days, this COC shall be final and
binding.
The subject farm is located in the Wilmington Regional Office. The Regional Office Water
Quality Staff may be reached at [phone]. If you need additional information concerning this
COC or the General Permit, please contact J R Joshi at [phone] ext. 363.
Sincerely,
_A. Preston Howard, Jr., P.E.
cc: (Certificate of Coverage only for all cc's)
Duplin County Health Department
Wilmington Regional Office, Water Quality Section
Duplin County Soil and Water Conservation District
Permit File

State of North Carolina R EC E11/t D40 Department of Environment and Natural Resoul�ei jR QUAi �iYS!*C�r
Division of Water Quality f�
Non -Discharge Permit Application Form JUN 2 4 1998-
(THIS FORM MAY BE PHOTOCOPIED FOR USE AS AN ORIGINAL.)
General Permit - Existing Liquid Animal Waste Operatians•mitung
The following questions have been completed utilizing information on fde.with the Division. Please
review the information for completeness and make any corrections which are appropriate. If a
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
1. GENERAL INFORMATION:
1.1 Facility Name: Bill McKay Farm
1.2 Print Land Owner's name: William McKay
1.3 Mailing address: 1516 Guman Powell Rd
City, State: Kenansville
Zip: 28349
Telephone Number (include area code): 910-296-0396, _.
1.4 County where facility is Iocated: DupZin ):
1.5 Facility Location (Directions frgm nearest major highway. Please include SR numbers: for state, roads. Please incIude�a
copy of a county road map with the location'of the farm identified): Take Hwy 24 east. from Kenansville. Approx.:T mile
_
outside KenansviIle. Turn left on to SR 1729tFarm is 1.7 miles'on the north side (left).
1.6 Print Farm Manager's name (i different from Land Owner):. 'r
1.7 Lessee's / Integrator's name (if applicable; please circle, which type is listed): Murphy Family. Farms
1.8 Date Facility Originally Began Operation. 1,01/01/88
19 'Date(s) of Facility Expansion(s) (if applicable) - - "
s 2 -,OPERATION-INFORMAT ION• iw
_ 2.-1 Facility No 31 ^ (county number), 13 fi ' (facility number).
2 2 Operation Description: Swrne _operation 4
y -
777
Fmrsh,
, -V„ r; < y Cernfied Desi Capacity
3672 r F
,• { ,L 7....� • •_. - r aS '' rr' 2 �*'� <!'._- T is the above information correct. yes; ` []no. R Ifno, correct below using the'design capacityofthe facility
.. 11, c`No =of Animals" should be the_maxnnum,num ear forNwhich the waste management structures were'designed.. f '
Type of Swine ~ No. of Animals Type of Poultry ; No. of Animals Type of Cattle ' No. of An.im, Ist'
Wean to Feeder,,
i- Feeder to'Finisl_'�=' - ( ' �: Non-LayerI
Farrow to Wean (# sow): r Turkey_
Farrow to Feeder (# sow).
Farrow to Finish (it sow ) J ?
Other Type -of Livestock on the farm: No_ of Aniciials: Al
FORM: AWO-G-E 5/28/98
Page 1 of 4 31 - 136

2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): 29.00 ; Required Acreage (as listed in the AWMP): 27
2.4 Number agoon storage ponds (circle which is applicable):
2.5 Are subsurface drains present within 100' of any of the application fields? YES or V(p
lease circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES orlease circle one)
2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, NRCS Standards, etc.) (Swine Only)
YES or NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited? - / - '97
What was the date that this facility's land application areas were sited? /Q - J - 8 %
3. REQUIRED ITEMS CHECKLIST —'
P!ease indicate that you have -included the following. required items by signing your initials in the'space provided neict to each
item.
Applicants Initials
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations; [
!L
3.2 Two copies of a general location map•indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
L
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
-
does not have a CAWMP, it must be completed prior to submittal of a general permit
application for animal waste operations.
The CAWMPmustinclude the following components:
-3.3.1. The=Waste,Utilization PIan (WUP) must include the amount of Plant Available
r y'
-Nitrogen (PAN )'produced' and utilized, by the facility.
`3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.) -
33.3 A map of every field.used for land application.
-3.3:4 .Tke soil series present on every.. land-application'field.
'-3.15 'on
..- -.The crops grown every,Iand application field: :"•
, �t����,���i�: ° �,
-3.3.6 ' -The Realistic Yield )xpectation (RYE) for'every.crop shown in the WUP.
{-3.3.7. The PAN applred'to every land application field.
,
-3:3:Sk °Tlie..w,rite:appiicatioii'M1.in ows for,every.crop`utiltzed in the WUP:
-3.3:9 =The required MRCS Standard speeificatioiis
i • 3.3.10 A site schematic `s r q • 7
-3.3.11' Emergency Acti'on.Plan:
-3.3.12 hisect Condo] Checklist with -chosen best'management practices noted.
. `3-3.13 Odor Contbl,ChecklistwIth chosen best management practices noted.
`i3.14'Iyl6rtality,Contr61 CQcklist with the selected method noted.
-3.3.15 Lagoon/storage pond'capacity:d6cumehtation',(design,.'calculations, etc.). Please be
P r
sure to include any site e�alitations weilandTd Gie inafions or ha zard.classifications " r
s
+ ,.�yt,�'
that may be'applicable td, our:facility
-".I6 Operation and Maintenance Plan
If your CAWMP�includes any.components not shown% on this please include the
�w� � al
•Itst,
. -additional eomponents:with your submittal: ° • ?' ,-- _ _
FORM: AWO-G-E, 5/28/98
Page 2 of 4 31 - 136

R
Facility Number: 31 - 136
Facility Name: Bill McKay Farm
4. APPLICANT'S CERTIFICATION:
I, (�Zu,',�,,,, m r- "---/ (Land Owner's name listed in question 1.2), attest that
this application for ,•// A- kc. V 6k r• I (Facility name listed in question 1.1)
has been reviewed by me and is accurate acid complete to the best of my knowledge. I understand that if all required parts of this -
application are not completed and that if all required supportin information and attachments are not included, this application
package will b re t e as incomplete.
1
?Signature Date 79'
5. MANAGER'S CERTIFICATION: (complete only iMifferent from the Land Owner)
I, (Manager's name listed in question L'6), attest that.this
a0plication.for (Facility name listed in question 1.1)
has'been reviewed by me and is accurateand complete to the best of my knowledge. I understand that if all required parts of -this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned as incomplete.
Signature I Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
•NON -DISCHARGE PERMITTING UNIT
-POST: OFFICE -BOX 29535
RALEIGH; NORTH CAROLINA 2762670535 ;
°TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
Z.
L
• •
,�fh.•".
4 y
•�
- T '' r£� _ _
. . ` i .
'ar•� 4 -`�'•i
. F .
S. � i �Y -f .� ..
�-
FORM: AWO-G-E- 5/28/98
Page 3 of 4 31 - 136

ANIMAL WASTE MAN;'. CEMENT PLAN CERTMCATTC� FOR EXISTIN%FEEDLOTS
WK i ER Qtfi;•'-f iY SEC-P.0%
Please return the completed form to the Division of Environmental Management at the address on the
reverse side of this form. AN 2.41998
,
Name of farm (Please print) J ,) ; y j , a w, r kG
Mailing Address: r ""`u"y
q Phone No.: qlo -,a q(. - is g to --
County (of farm): n tw',v�,
Farm location: Latitude and Longitude: 34 o s7' 53 7) a SV r fig". (required). Also, please attach a
copy of a county road map with location identified.
Type of operation (swine, layer, dairy, etc.)
Design capacity (number of animals) : l
Average size of operation (12 month population avg.): 3(7 2.
Average acreage needed for land application of waste (acres)
Technical Specialist Certification.
As a technical specialist designated by the North Carolina Soil and Water Conservation Commission pursuant
to 15A NCAC 6F .0005, - I certify that the existing animal waste management system for the farm named
above has an animal waste management plan that meets the operation and maintenance standards and
specifications of the Division of Environmental Management and the USDA - Soil Conservation Service
and/or the North Carolina Soil and Water Conservation Commission pursuant to 15A NCAC 2H.0217 and
15A NCAC 6F .0001 - .0005. The following elements and their corresponding minimum criteria have been
verified by me or other designated technical specialists and are included in the plan as applicable: minimum s`
separations (buffers); adequate quantity and amount of land for waste utilization (or use of third party);
access or ownership of proper waste application equipment; schedule for timing of applications; application
rates; loading rates; and the.control of the discharge of pollutants from stormwater runoff events less severe
than the 255 ear, 24 - hour storm. ,
When checked see reverse side of form f�
BILLY W. HOUSTON
Name, of Technical Specialist (Please Print):-- DUPLIN S & W CONSER. DIST.
Affiliation. (Agency): PO BQX,-27j7 KENANS.VIL-L_ E-NC
Address (Agency): TELEPHONE [phone] ' -
Signature:. A _ or !z 6 ! 4 6
� � .
Owner/Manager, Agreement.. - -
I (we) understand the operation aand maintenance procedures established in the approved animal waste
management plan for the farm named above and will implement these procedures. I (we) know that any
expansion to the existing design capacity of the waste treatment and storage system or construction of new
facilities will require•a new certification. to be submitted to the Division of Environmental Management
before the new animals are stocked. ,1,(we).also understand that there must be no discharge of animal waste.
from this system to surface waters of the state'either. directly through a. man-made conveyance or through
runoff from a storm event less severe that the 25-year, 24-hour storm. The approved plan will be filed at the
farm and at the office of the local Soil and Water Conservation District: r
Name of Land Q er. � (I, A c. K
Signature: K' , Date:
Name of Manager, if di feren o ow r.(Please print):
Signature: Date:_.. --
Mote: A change in land ownership requires notification or a new certification (if the approved plan is changed) within 60 days of a tide transfer.
DEM USE ONLY: ACE #

r4
wo
If
LS HLHoS
LU
L, ,

PRODUCER: WILLIAM P MCKAY
�l4 Gd� •�+ Pow.tl R.1
LOCATION:
KENANSVILLE
WASTE UTILIZATION (—AN PAGE 1
December 13, 1995
NC 28349
TELEPHONE: [phone]
TYPE OPERATION: Feeder to Finish Swine
NUMBER OF ANIMALS: 3672 hogs design capacity
The waste from your animal facility must be land applied at a specified
rate to prevent pollution of surface and/or groundwater. The plant,
nutrients in the animal waste should be used to reduce the amount of
commercial fertilizer required for the crops in the fields where waste
is to be applied. This waste utilization plan uses nitrogen as the
limiting nutrient. Waste should be analyzed before each application
cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important/in implementing your waste utilization
plan in order to maximize thelfertilizer value of the waste and to
ensure that it is -applied in an environmentally safe manner. Always_
apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not;apply more nitrogen than the crop can
utilize. Soil types -`are important as they have different infilitration
rates, leaching potentials, cation exchange capacities, and available
water holding capacities. Normally waste shall not be applied to land
eroding at greater than 5 tons per acre per year. With -special pre-
cautions, waste may be'applied:_to-:land-eroding_at.up-to-..10 tons..per
acre per year. Do not apply waste -on saturated -soils; when"it-is-:
s-
raining, or when the surfaces -.frozen. Either of these conditions
may result in runoff to surface waters which is not allowed under-DEM
regulations. Wind conditions should also be considered to avoid drift
and downwind odor problems.- To maximize the value of the nutrients.;_.
for crop production and to reduce the potential for pollution, the
waste should be applied to a growing crop or applied to bare ground.:
not more. than: 30 ;days prior -to planting. Injecting ,the 'waste or:---."
disking` will conserve-nut-r-ients .arid 'reduce odor problems'.
This plan is based;-ofi waste "application through irrigation _for this
is the mariner in which .you have chosen to apply your waste. If you
choose -to inject the waste in the, future, you -'need to revise this.—
plan. -Nutrient levels for inject-ing waste and irrigating.waste'are
ynot'the same.
The estimated acres needed''. -to' apply the animal .waste is based on.
typical nutrient content.T62r-this type of facility. Acreage require-
ments should be based on the-Mas:te analysis report from your waste:
management facility. Attached you will find.information.;onT.proper. _
sampling techniques, preparation, and transfer of -waste samples to
the lab for analysis.
This waste -utilization plan, if carried out,.meets the requirements
for compliance —with 15A NCAC 2H.0217 adopted b, the Environmental -
'Management Commission.

r r
WASTE UTILIZATION AN PAGE 2
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
3672 hogs x 1.9 tons waste/hogs/year = 6976.8 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
3672 hogs x 2.3 lbs PAN/hogs/year = 8445.6 lbs. PAN/year
Applying the above amount of waste is a big job. You should plan time
and have appropriate equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
f
T
A
i
i r+

WASTE UTILIZATION �'AN
TABLE 1: ACRES OWNED BY PRODUCER
PAGE 3
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
APPLIC.
TIME
4224
1
NOB
BH
6.1
305
0
2
610
APR-SEP
4224
--1
SG
I
11
150
1
12
1 SEP- ar,fl
4224
1B NOB
BH
6.1
3
1305
10_.
J915
APR-SEP
4224
-1B
SG
1
3
150
1
1150
SEP-
APP
4224
2
1i
BH
5460
JCRB
15.2
1260 1
121
IAPR-SEP-.
4224
SG
1
50
21
1050
1-2 1
SEP
Dh {
4
APR-- SEP
SEP-�lA�s�
A,ar. I
TOTAL 8610
1' Rlndicates,"that this field is being .overseeded .(I.e. interplanted)
or'winter annuals follow summer annuals.
-NOTE: The.applicator is cautioned that P and K may be -over applied
while meeting the N requirments. Beginning in 1996 the Coastal Zone
Management Act will.require farmers in.some eastern_ counties of NC to
have a nutrient -management plan, that addresses all nutrients. -This
plan only addresses Nitrogen.

~' WASTE UTILIZATION AN
PAGE 4
TABLE 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached
(Required only if operator does not own adequate
land. See required specification 2.)
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
APPLIC.
TIME
END
Indicates that this field is being overseeded (i.e. interpianted)
or winter annuals follow summer annuals.
In interplantedl fields (i.e. small grain, etc, interseeded
in bermudagrass), forage must be removed through grazing,
hay and/or silage. Where grazing, plants should be grazed
when they reach a height of six to nine inches. Cattle
should be removed when plants are grazed to a.height of four
inches. In fields where small grain, etc, is to be removed
for hay or silage, care should be exercised not to let small
grain reach -maturity, especially- late._-in_.the�- season-(i . e . .
April or May) . Shading 'may- result 'i£ small grain gets -too
high and this will definitely interfere with the stand of
bermudagrass. This loss of stand will result in reduced
yields.and, less nitrogen. being. utilized.. Rather than .
cutting small grain for.hay or silage just -before heading as
is the normal situation, you are encouraged to cut the small
"grain earlier. You may want to consider harvesting hay or
,silage two;:' to -three. times during., •,,thei season„' -depending on
`t.i.me small ' grain is planted in the fall.
.,.The -ideal time to interplant small grain, etc, is late
September or early October. Drilling 'is recommended over.
'broadcasting-.-- Bermudagrass. should --be grazed; or: mowed to a _
-height of about.two inches before drilling for best results.
** Acreage figures may exceed total.acreage infields due to
overseeding..
*�lbs AW N (animal waste nitrogen) equal's'total required nitrogen
less any commercial nitrogen (COMM-N),supplzed.

I�
WASTE UTILIZATION ( AN PAGE 5
The following legend explains the crop codes used in tables 1 and 2 above:
LBS N
CROP CODE
CROP
UNITS
PER UNIT
EH
HYBRID BERMUDAGRASS-HAY
TONS
50
SG
SMALL GRAIN OVERSEEDED
AC
50
TOTALS FROM TABLES 1 AND 2
N
, . TABLE 1 1. 27 1, 8610
TABLE 2 0
f
TOTAL 27 1
AMOUNT OF N PRODUCED
*** BALANCE,
1 8610
1 8445.6
, -164.4
i
This number must be less than or equal to 0 in order to
fully utilize the animal. -waste N produced.
Acres shown in each-af the preceding tables are considered to be the
usable acres excluding required buffers,. filter strips along ditches,
odd areas unable to be irrigated -,'and perimeter areas not receiving
full application rates due to equipment limitations. Actual total.
acres in the fields listed may, and most likely will be, more than
the acres shown in4.the tables,.
NOTE: The Waste Utilization Plan must contain provisions for periodic
land application of sludge at agronomic rates. The sludge will be -
nutrient rich and will require precautionary measures to prevent
over application of nutrients.or other elements. Your production..
facility will produce approximately'1358.64 pounds'of plant
available nitrogen (PAN) per -year in the sludge that will need'to be
removed.on a periodic basis. This figure is PAN when broadcasting
the sludge. Please be aware that.additional acres of larid,.as.well
special equipment;, maybe needed when you remove this. sludge...

WASTE UTILIZATION AN PAGE 6
See attached map showing the fields to be used for the utilization of
waste water.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of
the soil at the time of irrigation such that runoff or ponding occurs.
This rate is limited by initial soil moisture content, soil structure,
soil texture, water droplet size, and organic solids. The application
amount should not exceed the available water holding capacity of the
soil at the time of irrigation nor should the plant available nitrogen
applied exceed the nitrogen needs of the crop.
Your facility is designed for 135 days of temporary storage
and the temporary storage must be removed on the average of once every
4.5 months. In no instance should the volume of waste being stored in
your structure be within 1.7 feet of_the top of the dike.
If surface irrigation is the method of land application for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables 1 and12. Failure to apply the recommended rates and
amounts of Nitrogen shown in tAe tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report
for assistance in determining -the -amount -.of -,waste per..acre.and the proper
application rate prior to applying the -'-waste.
NARRATIVE OF OPERATION: e 3Guys
AV- C re p'Cea, tact ba %/ Gvf;_rs n+gL12-1 t I- 1 diV -C C►e�J.
�6 D U MtA a++ burr.., 13 S JmV%f
i

• T. WASTE UTILIZATION �� XN PAGE 7
Plans and Specification's
1. Animal waste shall not reach surface waters of the state by runoff,
drift, manmade conveyances, direct application, or direct discharge
during operation or land application. Any discharge of waste which
reaches surface water is prohibited. Illegal discharges are subject
to assessment of civil penalties of $10,000 per day by the Division
of Environmental Management for every day the discharge continues.
2. The Field Office must have documentation in the design folder that
the producer either has owns or has long term access to adequate
land to properly dispose of waste. If the producer does not own
adequate land to properly dispose of waste, he shall provide NRCS
with a copy of a written agreement with a landowner who is within
a reasonable proximity, allowing him/her the use of the land for
waste application for the life expectancy of the production
facility. It is the responsibility of the owner of the facility
to secure an update of the Waste Utilization Plan when there is
a change in the operation, increase in the number of -animals,
method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
Nitrogen needs for realistic crop~yields based on soil type,
available moisture, historical data, climate conditions, and
level of management, unless there are regulations that
rottrict the rate of application for other nutrients.
4. Animal waste may be applied to land that has a Resource
Management System (RMS) or.an Alternative Conservation System
(ACS). If an ACS is used the soil loss shall be no greater
than 10 tons per acre per year and appropriate filter strips
will be used where runoff leaves the field. These filter
strips will be in addition to "Buffers" required.by DEM.
(See FOTG Standard 393 - Filter strips -and Standard 390
interim Riparian Forest Buffers).
5.. Odors -can be reduced by injecting the waste or disking after'
waste application. Waste should not be applied when the
wind is blowing.
6. When animal waste.is to be applied -on acres subject to
flooding, it will be soil incorporated on conventionally
tilled cropland. When applied to conservation tilled crops
or grassland, the waste may be broadcast provided the
application does not occur during a season prone to
flooding. (See "Weather and Climate in North Carolina" in
the NRCS Technical Reference - Environment file for guidance.
7. Liquid waste shall_ be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or
to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur
in order to control conditions conducive to odor or flies
and to provide uniformity of application. -
8.- Animal waste shall not be applied to saturated soils, during
--' rainfall events, or when the surface is froien.
..9. Animal waste shall be applied on actively growing crops in
such a manner that no more than 20 to 25 percent of the leaf
area is covered.

�# WASTE UTILIZATION 4 �N PAGE 8
10. Waste nutrients -shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils
should be held to a minimum and a suitable winter cover
crop planted to take up released nutrients. Waste shall
not be applied more than 30 days prior to planting of a
crop on bare soil.
11. Animal waste shall not be applied closer than 25 feet to
surface water. This distance may be reduced for waters that
are not perennial provided adequate vegetative filter strips
are present. (See Standard 393 - Filter Strips)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 260 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other -
property and public right -of ways.
15. Animal waste shall not be discharged into surface wasters,
drainageways, or wetlands by discharge or by over -spraying.
Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site
by a "technical specialist". Animal waste should not be
applied on grassed waterways that discharge into water
courses, except when applied at agronomic rates and the
application causes no runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into
the animal waste management system-.
17. Lagoons and other uncovered -waste -containment structures
must maintain a maximum operating level to provide adequate
storage for.a.25-year, 24-hour storm event..in.addition.-to
one (1) foot mandatory freeboard.
18. A protective cover of appropriate vegetation will be
established.on all.disturbed areas -(lagoon embankments,
berms, pipe 'runs, etc.).' If needed, special' vegetation
shall be provided for these areas and shall'be-fenced,'as
necessary, to protect the vegetation. Vegetation such as
trees, shrubs, and other woody.species, etc: are limited to
areas where considered appropriate. Lagoon areas -should be
kept: mowed and .acces`sible--. Lagoon berms and, structures
should be inspected regularly for evidence of. erosion, leakage
or discharge..
19. If animal production at the facility is -to be suspended or
terminated, the owner is responsible,forobtaining.and'.imple-,
menti,ng a -"closure plan" which will eliminate the possibility
of an illegal discharge, pollution and erosion.-
1.20.. Waste handling structures, piping, - pumps" reels, etc., should
be inspected pn a regular basis to prevent. reakdowns, leaks,
and spills. A regular maintenance checklist should be kept
on site.

r
WASTE UTILIZATION Fl N PAGE 9
NAME OF FARM:
OWNER / MANAGER AGREEMENT
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the ap-
proved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new facilities
will require a new certification to be submitted to the Division of
Environmental Management (DEM) before the new animals -are stocked. I
(we) also understand that there must be no discharge of animal waste
from this system to surface waters of the state from a storm event
less severe than the 25 year, 24 hour storm. The approved plan will
be filed on -site at the farm office and at the office of the local
Soil and Water Conservation District and will be available for review
by DEM upon request.
I (we) understand that I must own or have access to equipment,
primarily irrigation equipment., to land apply the animal waste
described in this waste utilizationplan. This equipment must be
available at the appropriate pumping time such that no discharge
occurs from the lagoon in a 2�--year 1-day storm event. I also cer-
tify that the waste will` be applied on the land according to`this
plan at the appropriate times and -at rates thaCno runoff occurs.
NAME OF FACILITY OWNER: WILLIAM P MCKAY
SIGNATURE: fr' - GZDATE : 13 9 S T
NAME OF MANAGER (if different-- om owner):
please print
SIGNATURE: DATE
NAME OF TECHNICAL SPECIALIST: Johnny L. Lanier
AFFILIATION:— Duplin Soil and Watdr.Conservation District
: ADDRESS (AGENCY) : P . 0. Box 277 . ' - ,
Kenansvi•lle NC. 283.49,: -
SIGNATURE: - DATE:
-4tU ---

• �5=��=^__-,____-__==-=>Will��.a
McKay
Operator: =________=_=
County:__________________________==__==____=>Duplin
Date:====_____=______________________=__====>01/26
/96
-Dist. to nearest residence(other than owner):
ft.
sows (farrow to finish):____________________>
sows (farrow to feeder):____________________>
head (finishing only):______________________>
3672
sows (farrow to wean):===_=_________________>
head (wean to feeder):===___=______==_______>
Ave. Live Weight for other operations(lbs.):>
Storage volume for sludge accum. (cu. ft.):=>
Treatment Volume (min. 1 cu. ft./lb.):==____>
1.0
25 Year - 24 Hour Rainfall (in.):==--_-__-__>
7.5
Rainfall in excess -of evaporation (in.)===__>
7.0
Drainage area of buildings & lots (sq. ft.):>
Volume of wash water (gallons/day)====______>
Temporary storage period (days):=----_-__-__>
135
Freeboard{ft.):____________________________>
1
Side slopes (inside lagoon):________________>
2.4 1
Inside top length {ft.):==__________________>
365 _.
Inside top width (ft.):_____________________>
188.5
Top of dike elevation (ft.):________________>
36.2-
Bottom of lagoon elevation {ft.):==_-___=___>
21.8
Seasonal high water table(SHWT) elev.(ft:):=>
Total required volume:_____________> 669650
cu. ft.
Actual design volume:====______====>670749.55
cu. ft.
Stop pumping el. (> or =Fto 0 € 0 ft SHWT>
32.5 ft.
(> or = to 27.18 ft Min)
Required minimum treatment volume:; 495720
cu. ft.
Volume at stop pumping elevation: .501459
cu. ft.
Start pumping elev.:===--=-=====-W=______-_>
34.5 ft.
Volume at start pumping elevation: 625068
cu. ft.
Actual volume -less 25yr-24hr rain: 627748
cu. ft.-
NOTE:.Verify that temp. storage is adequate:
- Req. volume to be pumped:==='=s­ 130928
cu. ft.
Actual volume to be pumped:==>-. 12361b
cu. ft.

-NAME: Bill Mckay
ADDRESS. K'enar,svi Ile, N. G.
TYPE AND SIZE Topp i'nq Hogs
OF OPERATION 2448 -
GLASS
DESIGNED BY
DATE-
Jimmy Vinson
1G-1-G7
APPRi.1VED BY Jimmy Vinson
DATE 10-1-87
PERMAMENT STi iRAGE
2448 Hogs x 1 5'Iba.-per hog
TEMPORARY STORAGE
330480 l b 5 of animal x 1.35 c u. rf t_
3
3948-0 Cu Ft
80307 Cu Ft
per 1000 1 bs ct.f animal wt., : 1•-G days -
RAINFALL L'EEaS-EVAPORATION,
7" X 60300 sq.. ft. surface area per 12"per ft 351.75-•Gu,.F't'•,
RAINFALL - Z5 YR : 1-DAY STORM
7,5" X C�DBD�i q ft oaf surface area'' per- -1z" ,.pe.r7'ft: �•#ti7to 'Cut Ft
� H
wr t• _ TOTAL. STORAGE_ NEEDED... ,,4SS649:;.Cu Ft
tee, r�• .. t -n Gu 'Yds sr .
'TOTAL STGRA'CGE . AVA I LADLE t 49 200m, Cu -"Ft
1$489, Gu ;Yds.s
1- .� y F a �_ �� ♦ - i �, spit;ii s ,.+' j --L,
AMf7UNT L�F� FILL' D'KE" �'15DS8 Gu 'Ft�,
y,14 5aa4= CW EtFv 'i i {
+•?''4 7.r d-�1, - i-aL..pfFi? .r.•' ti ,� ,, ,t'� ,:.fS i d ,��. 4. tr,-aJy '� xiist�
r. v r r �.� ,t� -.•srY�L J- Z,-�7d j'G'', 1+i'�•
'•. :i s ya TCJTfkL''.
,'SETTLEMEIV.T- 10%
3 3 Gtit-
. rz 5 7 -7 � . •� � {' � � ' � '{`
_ � �,.•. r �J T y. .' It �:. .w _: ,f:,.h �y..'A... � ' �•R � �F.
£ _ �' ;• r TOT L AMOUNT1.,OF- FILL ?_ 321,yC-' Gu`FFt .
{ ,
a
',•, r, is �r �Nw­
�, #f11�171;'1utYd ,
GUT T FI`L`''L- RATIO �,� '€ �;,,TOTAL'.EX A1lATION �`428 O Cu,) �,{, `
� K 1 8 7- s iw
In
rt 'y` cf - i. -i tF.i� p_�:"Y• �y # jjr J�
' 1y •�(3p 'f Y Y 7 I T f.� y .�,�: 'S .f� �, `f�•_
_ � ay �� o #r i � � �! ,t r '• T°'r � '- •-' - r:ti, - t _• -+. rr ` — It �. �y .� Y:-•„t' t l ;�a..rR•���^° l3 'f
44
1 Cu Ft -per- -lb.
c4waste per day

5-
- NAME: Bill Mc k ay
APPROXIMATE NITROGEN CONTENT THAT WILL BE PRODUCED PER YEAR
NITROGEN (N) - 0.48 LBS PER 1 000 LBS OF ANIMAL WT . X 365 DAYS
(N) - 0.48 x 3--10480 x � 3 65
----------------------------------
1000
(N) - 57900 , 096 LBS
IT IS ESTIMATED THAT APPROXIMATELY 25 % OF THE NITROGEN WILL BE
AVAILABLE FOR USE AS FERTILIZER
THE FOLLOWING AMOUNT CAN DE APPLIED ON THE LAND
14475.024 LBS.
I '
IF APPLIED AT THE RATE OF 200 LBS PER ACRE ON CROPLAND
72.37512 ACRES WILL BE NEEDED TO i'AKE CARE OF THE EFFLUENT. �
IF APPLIED AT THE RATE OFF400 LDS PER ACRES'ON PASTURELAND-'(COASTA
36.18756 ACRES" W I LE-;bE NEEDED TO TAKE CAFE OF -THE, EFFLUENT.
BEFORE ANY EFFLUENT ,I S APPLIED ;TO - THE LAND,' I T SHOULD,' BE- ,'4 ALYZED-
TO DETERM I NE< "THE . EXAGT. NUTR I ENT. CONTENT . , T•HE NCDA .LABORATORY . r _
IN-RAL•EIGH IS MAKING,` SOME TEST ''ON A LIMITED BASIS.`;_'YOU :SHOULD
CONTACT _ aF �- •. ;, '...
AGRONOMIC:,SERV-ICES DIVISION.
NCDA7 " BLUE ,R'IDGE (ROAD;CENTER:
s t ,RALEIGH1 N' C t; - 7fa511 h '
PHONE: 91,9-733 - 655�
WHEN APPLYI NGrTHEFFLUEN7 PTO ,GF2iaFyLAN.D . I T 5HOULDwDEs aD I SK'AN_ D' As
COVEKI :C- OP' SEEDEDaR A KROW¢ GRElP' PLANTED *:TO PREVENT E R 0 S I 0 N 1
G..
SOME OF T.HE EFFLUENTj,7C LI3 SCE USED =Fulti; IRRdGATION FUFiPOSES
DlJR I NG THE GROWING% SEASON .a 1, � 'k`r'
_ .;•.. �;.;, `Se 1 --•i.:'�i '�3.a�'ri: sf'eEk -)� � rai * {7 i _ - • a ; Y = 1, .F r - =r 1 yfi
aC� -AC CIF LANDS AVA I QABE FGR -AFPL i CRTDI GN OF � EFFLUENT :
s .}
f w. a!_{f �'•� - ;%]S 4t . r i -.:k
1 x�
BEGIN PUMP ING - THE _EFFLUENTr- -WHEN: . 1 yp$�, '
THE FLUID LEVEL kb; t-_Hts' �'"? ; B;� .iD, ft , el,_ev .
. -.. .. . h-Y.. ,. _ a ��-4. -�1 ����']c .`� — ____ — _�1' •r +ii' `• -fig} -
DO NOT LOWER :THE FL.0 I D ANY'
-LOWER THANt` I
THLP-'EFFLUENT SHOULD�BE APPLIED. AT, -A -RATE HAT WILL QT., .,CAUSE,,.ANY "
RUNOFF ONTO SURROUND4 NG AREAS. OR.';LEACH I NG _INTO fHFJ=GR0lJND
RECOMMENDED _APPPL I CATION RATE: 'Is 0.5 INCHES PER HOUR .AND• THE
MAXIMUM RECOMMENDED APPLICATION AMOUNT IS f INCH PER I'RRGATION

r,
-NAME. Lill Mckay
SEEDING SPECIFICATIONS
AREA TO BE SEEDED 4 AC.
APPLY THE FOLLOWING
4000 LBS. 8-8-8 FERTILIZER
S -TONS DOLOMITIC- LIMESTONE
400 BALES -SMALL GRAIN STRAW
USE THE SEED MIXTURE
INDICATED -
(;:) 200 .LBE. FESCUE GRASS
(A) 140 LBS: `OATS
( ) 2010 LBS. BAHIA GRASS
t 3 16 LBS.IWEERING LOVE GRASS
( ) 4S LBS.-HULLED-BERMUDA GRASS
(- ) SD L_ BS. ,UNHUL_ LED BERMUDA GRASS
DIVERT ,ALL -.WATER TO `A' STABL-E OUTLE• - .• u; - .'.
THE .NEAREST RESIDENCE IS '' 1500 FT..
.fF f < ad w T� i- t }� - j . � Y 5 � `r r r 3,y: r _ � °.• -✓ �•2�' '1' t a 4rq �"
T:L'M.`Fr U50;O-",' E E
ti.4Vi4TI�pIV'
} *- -I-
DESCRIPTION TaFl�af ba.l • YI-read of .ate �fas t' 4 Y�
' 4 .. t. '��- D•: �Fl i 1i7 r1 .w � ,- ar - �y' y."� d: 4 oaf' r
4 _. - '4i — — n l! • .4 _ � ��l"�""'�F . � - r- ..,f _4fS�� ' F r -t' t
- ., � - _ c� ,• fir'. - � k �f� ' � n � t, --
t- 2�;`r
•-1 r •'fir -• t; ,

NAME: B i I I Mckay
DEPTH [ AREA OF TOP + AREA OF BOTTOM + 4 Y. AREA OF MIDSECTION]
VOLUME=-----------------------------------------------------------
6.0 7
DEPTH [ L W + L X W+ 4 X L X W 7
VOLUME=------------------------------------------------
6 27
12.0 [ 325 ?( 170 + 265 X 110 + 4 X 295 X 1401
VOLUME=---------_---------------------------------------------_--�_
6 . G 2.7
12.0 [ 2496001
VOLUME =-----------------
.G 27
499ZO0 . G CU . FT.
VOLUME-----27. G�
VOLUME = 18488.9 CU. YDS..
_ 483644 .. 1 tu.i ft:. :n); e,dad-_„
Sl DE,',SLQF'_ES
' t
,NTH. '�'/ } �i�-'`:t t t - q9• i �. •' d E a i - •4.Sn� '. Y: '3{i . y ; f-- ''! _
- - 5 _ LL� r 4. '-,y� ee. �� ,F�.a• ,.7.f,f } < r.F -i '� .%.-� 3,r'£' i •ny eb.,�•., f
,f �5�'. 1 3„�y.�i � k ¢ S•t +i �.
f+ ic- ��" -Y k -t 1 : w.. +i .r. .? '�c' ' . •'4': 2•+ tyr ', ,y --.
L- - - _ * r t.+w 4 ,r- J �', x ^ i } rr _ .. ,. . Z7£a�; `, ?`.'•,��}.
,'�r� � ' „ , t i'.i. :ri � _ f _� itl �� _ ` - F.�/��,. # �i .'y'�'Y�a i a ... y y�} � , ' •. k. d,• � ,tx ).-� s
� t -. 1 .} k ,• f ,. ;ir J ; Y 3r"T n 3 prT}".. r '' l�r'_+ �. ;i"z ��`s.� 'c'•i_•-
4 x• '". L - l i�} ,. i. i T!. 1 y},f, •;,A ).' Sa•}^`jf�.{y.T _ ��j 1 T.'.l+ a-_
It
a�_ -�iI �! ' h. � k 1 4••, { p r �^I} '1,, � h 14. ��(� i t S ,l 1. f tk,'. .5t•'{..
-tie-jF
a - - Yt, • b r� A �&'tyy' 6 f W 1' � I` ri' f' f

A S: Y'
!"" as � it ` ,y may, �.w �>,,
yJ , �,
� _��_i[ry
�.. s� � ��Y� lam'• �, r����Vf '�
[� - o .¢ 3 � �R;. �..c
yi�'�1�z s". �14 !'
y.. Ayr- yrJ. 3r ♦ at -...
- L� a'= ._
'. / - x
4 �. L} S L_ J .. 3 �

RECF-IVED
Wp i ER QUALI1' SECT
EMERGENCY ACTION PLAN
PHONE NUMBERS
DIVISION OF WATER QUALITY (DWQ)
EMERGENCY MANAGEMNET SERVICES (EMS)
SOIL AND WATER CONSERVATION DISTRICT (SWCD)
NATURAL RESOURCES CONSERVATION SERVICE (NRCS)
COOPERATIVE EXTERSION SERVICE (CES)
JUN 2 41998
Non -Discharge Permitting
[phone]
[phone]
(91'0)296-2120
[phone]
[phone]
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing or running off site. You should not wait until wastes reach surface waters
or leave you property to consider that you have a problem. You should make every
effort to ensure that this does not happen. This plan should be posted in an accessible
location for all employees at the facility. The following are some action items you should
to ke.
1. Stop the release of wastes. Depending on the situation, this may ore may not be
possible. Suggested responses to some possible problems are listed belwo.
A. Lagoon overflow -possible solutions are:
a. Add soil` to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon,
B. Runoff from waste application field -actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that cause the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
D. Leakage from flush systems, houses, solid separators -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed
to flowing leaks -possible action:
a. Dig a small sump or ditch from the embankment to catch all
seepage, put in a submersible pump, and pump back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon
bottom as soon as possible.
1

2. Assess the extent of the spill and note any obvious damages.
a. Did the waste. reach any surface waters?
b. Approximately how much was released and for what duration?
c. Any damage notes, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours call your DWQ regional office; Phone - -. After
hours, emergency number: 919-733-3942. Your phone call should include: your
name, facility number, telephone number, the details of the incident from item 2
above, the exact location of the facility, the location or direction of movement of
the spill, weather and wind conditions. --The corrective measures that have been
under taken, and the seriousness of the sitution.
b. If spill leaves property or enters surface waters, call local EMS phone number.
c. Instruct EMS to contact local Helath Department.
d. Contact CEs, phone number - , local SWCD office phone number - -, and local
NRCS office for advice/technical assistance phone number - -.
4. If none of the above works call 911 or the Sheriff's Department and explain you
problem to them and ask the person to contact the proper agencies for you.
5. Contact the contractor of your choice to begin repair or problem to minimize off -
site damage.
a. Contractors Name: Ali
b. Contractors Address:
c. Contractors Phone: 9i0 - SfR -,Q1/ /
6. Contact the technical specialist who certified the lagoon (NRCS, Consulting
Engineer, etc.)
a. Name: � a
b. Phone: 116 -
t
r
7. Implement procedures as advised by DWQ and technical assistance agencies to
rectify the damage, repair the system, and reassess the waste managment plan to
keep problems with release of wastes from happening again.
2

REC 1VED
V TERQUA tiY0KC-T,Ci
JUN 2 41998
OPERATION & MAINTENANCE PLAN
iar-� h raa Pe.rmi rig
Proper lagoon liquid management should be a year-round priority. It is especially
important to manage levels so that you do not have problems during extended rainy and
wet periods.
Maximum storage capacity should be available in the lagoon for periods when the
receiving crop is dormant (such as wintertime for bermudagrass) or when there are
extended rainy spells such as the thunderstorm season in the summertime. This means
that at the first signs of plant growth in the later winter/early spring, irrigation according to
a farm waste management plan should be done whenever the land is dry enough to
receive lagoon liquid. This will make storage space available in the lagoon for future wet
periods. In the late summer/early fall the lagoon should be pumped down to the low
marker (see Figure 2-1) to allow for winter storage. Every effort should be made to
maintain the lagoon close to the minimum liquid level as long as the weather and waste
utilization plan will allow it.
Waiting until the lagoon has reached its maximum storage capacity before starting to
irrigate does not leave room for storing excess water during extended wet periods.
Overflow from the lagoon for any reason except a 25-year, 24-hour storm is a violation of
state law and subject to penalty action. `
The routine maintenance of a lagoon involves the following:
Maintenance of a vegetative cover for the dam.
Fescue or common bermudagrass are the most common vegetative
covers. The vegetation should be fertilized each year, if needed, to
maintain a vigorous stand. The amount of fertilizer applied should be
based on a soils test, but in the event that it is not practical to obtain
a soils test each year, the lagoon embankment and surrounding areas
should be fertilized with 800 pounds per acre of 10-10-10, or
equivalent.
Brush and trees on the embankment must be controlled. This may be
done by mowing, spraying, grazing, chopping, or a combination of
these practices. This should be done at least once a year and
possibly twice in years that weather conditions are favorable for
heavy vegetative growth.
NOTE: If vegetation is controlled by spraying, the herbicide must not be allowed to enter
the lagoon water_ Such chemicals could harm the bacteria in the lagoon that are treating
the waste.
Maintenance inspections of the entire lagoon should be made during the initial filling of
the lagoon and at least monthly and after major rainfall and storm events. Items to be
checked should include, as a minimum, the following:
Waste Inlet Pipes, Recycling Pipes, and Overflow Pipes ---look for:
1. separation of joints
2. cracks or breaks
3. accumulation of salts or minerals
4. overall condition of pipes

Lagoon surface ---look for:
1. undesirable vegetative growth
2. floating or lodged debris
Embankment ---look for:
1. settlement, cracking, or "jug" holes
2, side slope stability ---slumps or bulges
3. wet or damp areas on the back slope
4. erosion due to lack of vegetation or as a result of wave action
5. rodent damage
Larger lagoons may be subject to liner damage due to wave action caused by strong
winds. These waves can erode the lagoon sidewalls, thereby weakening the lagoon dam.
A good stand of vegetation will reduce the potential damage caused by wave action. If
wave action causes serious damage to a lagoon sidewall, baffles in the lagoon may be
used to reduce the wave impacts.
Any of these features could lead to erosion and -weakening of the dam. If your lagoon has
any of these features, you should call an appropriate expert familiar with design and
construction of waste lagoons. You may need to provide a temporary fix if there is a threat
of a waste discharge. However, a permanent solution should be reviewed by the
technical expert. Any digging into a lagoon dam with heavy equipment is a serious
undertaking with potentially serious consequences and should not be conducted unless
recommended by an appropriate technical expert.
Transfer Pumps ---check for proper operation of:
1. recycling pumps
2. irrigation pumps
Check for leaks, loose fittings, and overall pump operation. An unusually loud or grinding
noise, or a large amount of vibration, may indicate that the pump is in need or repair or
replacement.
NOTE: Pumping systems should be inspected and operated frequently enough so that you
are not completely "surprised" by equipment failure. You should perform your pumping
system maintenance at a time when your lagoon is at its low level. This will allow some
safety time should major repairs be required. Having a nearly full lagoon is not the time
to think about switching, repairing , or borrowing pumps. Probably, if your lagoon is full,
your.neighbor's lagoon is full also. You should consider maintaining an inventory of spare
parts or pumps.
Surface water diversion features are designed to carry all surface
drainage waters (such as rainfall runoff, roof drainage, gutter outlets,
and parldng lot runoff} away from your lagoon and other waste
treatment or storage structures. The only water that should be
coming from your lagoon is that which comes from your flushing
(washing) system pipes and the rainfall that hits the lagoon directly.
You should inspect your diversion system for the following:
1. adequate vegetation
2. diversion capacity
3. ridge berm height

Identified problems should be corrected promptly. It is advisable to inspect your system
during or immediately following a heavy rain. If technical assistance is needed to
determine proper solutions, consult with appropriate experts.
You should record the level of the lagoon just prior to when rain is predicted, and then
record the level again 4 to 6 hours after the rain (assumes there is no pumping). This will
give you an idea of how much your lagoon level will rise with a certain rainfall amount
(you must also be recording your rainfall for this to work). Knowing this should help in
planning irrigation applications and storage. If your lagoon rises excessively, you may
have an inflow problem from a surface water diversion or there may be seepage into the
lagoon from the surrounding land.
Lagoon Operation
Startup:
1. Immediately after construction establish a complete sod cover on bare soil
surfaces to avoid erosion.
2. Fill new lagoon design treatment volume at least half full of water before
waste loading begins, taking care not to erode lining or bank slopes.
3. Drainpipes into the lagoon should have a flexible pipe extender on the
end of the pipe to discharge near the bottom of the lagoon during initial
filling or another means of slowing the incoming water to avoid erosion of
the lining.
4. When possible, begin loading new lagoons in the spring.to maximize
bacterial establishment. (due to warmer weather).
5. It is recommended that a new lagoon be seeded with sludge from a healthy
working swine lagoon in the amount of 0.25 percent of the full lagoon
liquid volume. This seeding should occour at least two weeks prior to the
addition of wastewater.
6. Maintain a periodic check on the lagoon liquid pH. If the pH falls below
7.0, add agricultural lime at the rate of 1 pound per 1000 cubic feet of
lagoon Iiquid volume until the pH rises above 7.0. Optimum lagoon liquid
pH is between 7.5 and 8.0.
7. A dark color, lack of bubbling, and excessive odor signals inadequate
biological activity. Consultation with a technical specialist is recommended
if these conditions occur for prolonged periods, especially during the warm
season.
Loading:
The more frequently and regularly that wastewater is added to a lagoon, the better the
lagoon will function. Flush systems that wash waste into the lagoon several times daily are
optimum for treatment. Pit recharge systems, in which one or more buildings are.drained
and recharged each day, also work well.

Practice water conservation ---minimize building water usage and
spillage from leaking waterers, broken pipes and washdown through
proper maintenance and water conservation.
Minimize feed wastage and spillage by keeping feeders adjusted. This
will reduce the amount of solids entering the lagoon
Management:
Maintain lagoon liquid level between the permanent storage level and
the full temporary storage level.
Place visible markers or stakes on the lagoon bank to show the
minimum liquid level and the maximum liquid lever (Figure 2-1).
Start irrigating 'at the earliest possible date iri the spring based on
nutrient requirements and soil moisture so that temporary storage
will be maximized for the summer thunderstorm season. Similarly,
irrigate in the late summer/early fall to provide maximum lagoon
storage for the winter.
The lagoon liquid level should never be closer than 1 foot to the lowest
point of the dam or embankment.
Do not pump the lagoon liquid level lower that the permanent storage
level unless you are removing sludge.
Locate float pump intakes approximately 18 inches underneath the liquid
surface and as far away from the drainpipe inlets as possible.
Prevent additions of bedding materials, long-stemmed forage or vegetation,
molded feed, plastic syringes, or other foreign materials into the lagoon.
Frequently remove solids from catch basins at end of confinement houses or
wherever they are installed.
Maintain strict vegetation, rodent, and varmint control near lagoon edges.
Do not allow trees or large bushes to grow on lagoon dam or embankment.
Remove sludge froni the lagoon either when the sludge storage capacity is
full or before it fills SO percent of the permanent storage volume.
If animal production is to be terminated, the owner .is responsible for
obtaining and implementing a closure plan to eliminate the possibility_of a
pollutant discharge.
Sludge Removal:
Rate of lagoon sludge buildup can be reduced by:

proper Iagoon sizing,
mechanical solids separation of flushed waste,
gravity settling of flushed waste solids in an appropriately designed basin, or
minimizing feed wastage and spillage.
Lagoon sludge that is removed annually rather than stored long term will:
have more nutrients,
have more odor, and
require more land to properly use the nutrients.
Removal techniques:
Hire a custom applicator. .
Mix the sludge and lagoon liquid with a chopper -agitator impeller _
pump through large -bore sprinkler irrigation system onto nearby cropland;
and soil incorporate.
Dewater the upper part of lagoon by irrigation onto nearby cropland or
forageland; mix remaining sludge; pump into liquid sludge applicator; haul
and spread onto cropland or forageland; and soil incorporate.
Dewater the upper part of lagoon by irrigation onto nearby cropland or
forageland; dredge sludge from lagoon with dragline or sludge barge; berm
an area beside lagoon to receive the sludge so that liquids can drain back
into lagoon; allow sludge to dewater; haul and spread with manure spreader
onto cropland or forageland; and soil incorporate.
Regardless of the method, you must have the sludge material analyzed for waste
constituents just as you would your lagoon water. The sludge will contain different
nutrient and metal values from the liquid. The application of the sludge to fields will be
limited by these nutrients as well as any previous waste applications to that field and crop
requirement. Waste application .rates will be discussed in detail in Chapter 3.
When removing sludge, you must also pay attention to the liner to prevent damage. Close
attention by the pumper or drag -line operator will ensure that the lagoon liner remains
intact. If you see soil material or the synthetic liner material being disturbed, you should
stop the activity immediately and not resume until you are sure that the sludge can be
removed without liner injury. If the liner is damaged it must be repaired as soon as
possible.
Sludge removed from the lagoon has a much higher phosphorus and heavy metal content
than liquid. Because of this it should probably be applied to land with low phosphorus
and metal levels, as indicated by a soil test, and incorporated to reduce the chance of
erosion. Note that if the sludge is applied to fields with very high soil -test phosphores, it
should be applied only at rates equal to the crop removal of phosphorus. As with other
wastes, always have your lagoon sludge analyzed for its nutrient value.
The application of sludge will increase the amount of odor at the waste application site.
Extra precaution should be used to observe the wind direction and other conditions which
could increase the concern of neighbors.

Possible Causes of Lagoon Failure
Lagoon failures result in the unplanned discharge of wastewater from the structure. Types
of failures include leakage through the bottom or sides, overtopping, and breach of the
dam. Assuming proper design and construction, the owner has the responsibility for
ensuring structure safety. Items which may lead to lagoon failures include:
Modification of the lagoon structure ---an example is the placement of a pipe
in the dam without proper design and construction. (Consult an expert in
lagoon design before placing any pipes in dams.)
Lagoon liquid levels ---high levels are a safety risk.
Failure to inspect and maintain the dam.
Excess surface water flowing into the lagoon.
Liner integrity ---protect from inlet pipe scouring, damage during sludge
removal, or rupture from lowering lagoon liquid level below groundwater
table. < <
NOTE: If lagoon water is allowed to overtop the dam, the moving water will soon cause
gullies to form in the dam. Once this damage starts, it can quickly cause a large discharge
of wastewater and possible dam failure.

VV II ER QL'-' i Y 8EG'i :0i�1
JUN 2 41998
INSECT CONTROL CHECKLIST FOR ANIMAL OPERATIONS.
Source Cause BMP's to Minimize Odor Site Specific Practices
(Liquid Systems)
Flush Gutters Accumulation of solids (4<ush system is designed and operated
sufficiently to remove accumulated
solids from gutters as designed.
move bridging of accumulated solids at
discharge
Lagoons and Pits Crusted Solids O Maintain lagoons, settling basins and
pits where pest breeding is apparent to
minimize the crusting of solids to a depth
of no more than 6-8 inches over more than
30% of surface.
Excessive Vegetative Decaying vegetation { -Maintain vegetative control along banks of
Growth lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along water's edge on impoundment's perimeter.
(Dry Systems)
Feeders Feed Spillage (I Design, operate and maintain feed systems (e.g.,
bunkers and troughs) to minimize the accumulation
of decaying wastage.
() Clean up spillage on a routine basis (e.g. 7-10 day
interval during summer; 15-30 day interval during winter).
Feed Storage Accumulations of feed residues {) Reduce moisture accumulation within and around
immediate perimeter of feed storage areas by
insuring drainage away from site and/or providing
adequate containment (e.g., covered bin for
brewer's grain and similar high moisturd grain
products).
{) Inspect for and remove or break up accumulated
solids in filter strips around feed storage as needed.
Animal Holding Areas Accumulations of animal wastes [) Eliminate low area that trap moisture along fences
and feed wastage and other locations where waste accumulates and
and disturbance by animals is minimal.
1 ) Maintain fence rows and filter strips around animal
holding areas to minimize accumulations of wastes
(i.e. inspect for and remove or break up accumulated
solids as needed).
AMIC--November 11, 1996

Dry Manure Handling Accumulations of animal wastes 1) Remove spillage on a routine basis (e.g. 7-10 day
Systems interval during summer; 15-30 days interval during
winter) where manure is loaded for land application
or disposal.
11 Provide for adequate drainage around manure stockpiles.
1 1 Inspect for and remove or break up accumulated wastes
in filter stripes around stockpiles and manure handling
areas as needed.
The issues checked ( ) pertain to this operation. The landowner/integrator agrees to use sound judgment in applying
insect control measures as practical.
I certify the aforementioned insect control Best Management Practices have been reviewed with me.
_J11A,1L�1 IP
(L downer Signet re
For more information contact the Cooperative Extension Service, Department of Entomology, Box 7613, North Carolina State University, Raleigh, NC
27695-7613.
AMIC--November 11, 1996

SWINE FARM WASTE MANAGEMENT ODOR CONTROL. CHECKLIST
Source Cause BMP's to Minimize Odor Site Specific Practices
Farmstead Swine production eg bve or wooded buffers;
ecommended best management
practices;
ood judgment and common sense
Animal body surfaces Dirtv manure -covered animals { 1 Dry floors
Floor surfaces Wet manure -covered floors (0-Slo'tted floors;
erers located over slotted floors;
1) Feeders at high end of solid floors;
crape manure buildup from floors;
{) Underflooi ventilation for drying
Manure collection pits Urine H-Fiaquent manure removal by flush,pit
recharge,or scrape
Paritaf micorbial decomposition (} Underfloor ventilation
Ventilation exhaust fans Volatile gases; 1.) F n maintenance;
Dust icient air movement
Indoor surfaces
Dust
41-Washdown between groups of animals
{) Food additives;
{) Feeder covers;
(} Feed delivery downspout extenders to
feeder covers
Flush tanks
Agitation of recycled lagoon
() Flush tank covers
liquid whiles tanks are filling
(I Extend fill lines to near bottom of
tanks with anti -siphon vents
Flush alleys
Agitation during wastewater
{ ) Underfloor flush with underfloor
conveyanance %
ventilation
Pit recharge points
Agitation of recycled lagoon
(} Extend rechard lines to near bottom of
liquid while pits are filling
pits with anti -siphon vents
Lift stations
Agitation during sump tank filling
{) Sump tank covers
and drawdown
Outside drain collection
Agitation during wastewater
{) Box covers
or junction boxes
conveyance
End of drainpipes at lagoon
Agitation during wastewater
(} Extend discharge point of pipes
underneath lagoon liquid level
Lagoon surfaces
Volatile gas emissions
hj-Proper lagoon liquid capacity
Biological mixing
W-Correct lagoon startup procedures
Agitation
(4Minimum surface area -to -volume ratio
++-Minimum agitation when pumping
( I Mechanical aeration
{ I Proven biological additives
i
Irrigation sprinkler nozzles
High pressure agitation
('rTr—rigate-on dry days with little or no wind
Wind draft
m recommended operation pressure
ump intake near lagoon liquid surface
I ) Pump from second -stage lagoon
AMOG--November 11, 1996

Storage tank or basin Partial microbial decomposition
O Bottom or midlevel loading
surface Mixing while filling
() Tank covers
Agitation when emptying
{ } Basin surface mats of solids
) Proven biological additives or oxidants
Settling basin surface Partial micobial decomposition
( ) Extend drainpipe outlets underneath liquid
Mixing while filling
level
Agitation when emptying
( ) Remove settled solids regularly
Manure, slurry or sludge Agitation when spreading
( ) Soil injection of slurry/sludges
spreader outlets Volatile gas emissions
( ) Wash residual manure from spreader after use
{ ) Proven biological additives or oxidants
Uncovered manure, slurry Volatile gas emissions while drying ( ) Soil infection of slurry/sludges
or sludge on field surfaces
( ) Soil incorporation within 48 hours
( ) Spread in thin uniform layers for rapid drying
( I Proven biological additives or oxidants
Dead animals Carcass decomposition
H-Proper disposition of carcasses
Dead animal disposal Carcass decomposition
( I Complete covering of carcasses in burial pits
Pits
{ ) Proper location/construction of disposal pits
Incinerators Incomplete combustion
( ) Secondary stack burners
Standing water around Improper drainage
{ ) Grade and landscape such that water drains
facilities Microbial decomposition of
away from facilities
organic matter
Manure tracked onto public Poorly maintained access roads
arm access road maintenance
roads from farm access
Additional Information:
Available From:
Swine Manure Management; 0200 Rule/BMP'Packet
NCSU-County Extension Center
Swine Production Farm Potential Odor Sources and Remedies,
EBAE Fact Sheet
NCSU-BAE
Swine Production Facility Manure Management: Pit Recharge —Lagoon Treatment; EBAE 128-88
NCSU-BAE
Swine Production Facility Manure Management: Underfloor Fluse--Lagoon Treatment; EBAE 129-88
NCSU-BAE
Lagoon Desig and Management for Livestock Manure Treatment and Storage; EBAE 103-83
NCSU-BAE
Calibration of Manure and Wastewater Application Equipment;
EBAE Fact Sheet
NCSU-BAE
Controlling Odors from Swine Buildings; PEH-33
NCSU-Swine Extension
Environmental Assurenc Program: NPPC Manuel
NC Pork Produces Assoc
Options for Managing Odor; a report from the swine Odor Task Force
NCSU Agri Communications
Nuisance Concerns in Animal Manure Management: Odors and Fries; PRO107, 1995 Conference Proceedings
Florida Cooperative Extension
The issues checked pertain to this operation.
The landowner/integrator agrees to use sound judgment in applying
odor control measures as practical.
I certify the aforementioned odor control Best Managment Practices have been reviewed with me.
r
(Lando n r Signat O
AMOC--November 11, 1996

MORTALITY MANAGEMENT METHODS
(check which method(s) are being implemented)
{ j Burial three feet beneath the surface of the ground within 24 hours
after knowledge of the death. The burial be at least 300 feet from
any flowing steam or public body of water.
( Rendering at a rendering plant licensed under G. S. 106-168.7
( ) Complete incineration
( } In the case of dead poultry only, placing in a disposal pit of a size and
design approved by the Department of Agriculture.
{ j Any method which in the professional opinion of the State
Veterinarian would make possible the salvage of part of a dead
animal's value without endangering human or animal health. (Written
approval of the State Veterinarian must be attached)

System Calibration
Information presented in manufacturer's charts are based on average operation
conditions with relatively new equipment. Discharge rates and application rates
change over time as equipment gets older and components wear. In particular,
pump wear tends to reduce operating pressure and flow. With continued use,
nozzle wear results in an increase in the nozzle opening which will increase the
discharge rate while decreasing the wetted diameter..
You should be aware that operating the system differently than assumed in the
design will alter the application rate, diameter of coverage, and subsequently the
application uniformity. For example, operating the system with excessive pressure
results in smaller droplets, greater potential for drift, and accelerates wear of the
sprinkler nozzle. Clogging of nozzles can result in pressure increase. Plugged
intakes or crystallization of mainlines will reduce operating pressure. Operating
below design pressure greatly reduces the -coverage diameter and application
uniformity.
For the above reason, you should calibrate your equipment on a regular basis to
ensure proper application rates and uniformity. Calibration at least once every
three years is recommended. Calibration involves collecting and measuring flow at
several locations in the.application area. Any number of containers can be used to
collect flow and determine the application rate. Rain gauges work best because
they already have a graduated scale from which to read the application amount
without having to perform additional calculations. However, pans, plastic buckets,
jars, or anything with a uniform opening and cross-section can be used provided
the liquid collected can be easily transferred to a scaled container for measuring.
For stationary sprinklers, collection containers should be located randomly
throughout the application area at several distances from sprinklers. For traveling
guns, sprinklers should be located along a transect perpendicular to the direction
of pull. Set out collection containers 25 feet apart along the transect on both
sides of the gun cart. You should compute the average application rate for all
nonuniformity of the application. On a windless day, variation between containers
of more than 30 percent is cause for concern. You should contact your irrigation
dealer or technical specialist for assistance.
*Reprinted for Certification Training for Operations of Animal Waste Management Systems Manual

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor L
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
May 29, 1998
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
VW1 i iam McKay
Bill McKay Farm
1516 Guman Powell Rd
Kenansville NC 28349
Farm Number: 31 -136
Dear William McKay:
ECEIVEDXTU
JUN U 41998 Z• �
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
You are hereby notified that Bill McKay Farm, in accordance with G.S. 143-215.1OC, must
apply for coverage under an Animal Waste Operation General Permit. Upon receipt of.this letter, your
farm has sixty (60) days to submit the attached- application and all supporting documentation. In
accordance with Chapter 626 of 1995 Session Laws (Regular Session 1996), Section 19(c)(2), any
owner or operator who fails to submit an application by the date specified by the Department
SHALL NOT OPERATE the animal waste system after the specified date. Your application must
be returned within sixty (60) days of receipt of this letter. Failure to submit the application as required
may also subject your facility to a civil penalty and other enforcement actions for each day the facility is
operated following the due date of the application.
The attached application has been partially completed using information listed in your Animal
Waste Management Plan Certification Form. if any of the general or operation information listed is
incorrect please make corrections as noted on the application before returning the application package.
The signed original application, one copy of the signed application, two copies of a general location
map, and two copies of the Certified Animal Waste Management Plan must be returned to complete the
application package. The completed package should be sent to the following address:
North Carolina Division of Water Quality
Water Quality Section
Non -Discharge Permitting Unit
Post Office Box 29535
Raleigh, NC 27626-0535
If you have any questions concerning this letter, please call Sue Homewood at [phone]
extension 502 or Dave Holsinger with the Wilmington Regional Office at [phone].
cc: Permit File (w/o encl.)
Wilmington Regional Office (w/o encl.)
Sincerely,
A. Preston Howard, Jr., P.E.
�ar
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

State of North Carolina
Department of Environment,
Health and Natural Resources
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
November 13, 1996
William McKay
Bill McKay Farm
1516 Guman Powell Rd
Kenansville NC 28349
SUBJECT: Operator In Charge Designation
Facility: Bill McKay Farm
Facility ID#: 31-136
Duplin County
Dear Mr. McKay:
Senate Bill 1217, An Act to Implement Recommendations of the Blue Ribbon Study
Commission on Agricultural Waste, enacted by the 1996 North Carolina General Assembly,
requires a certified operator for each animal waste management system that serves 250 or more
swine by January 1, 1997. The owner of each animal waste management system must submit a
designation form to the Technical Assistance and Certification Group which designates an
Operator in Charge and is countersigned by the certified operator. The enclosed form must be
submitted by January 1, 1997 for all facilities in operation as of that date. Failure to designate a
certified operator for your animal waste management system is a violation of 15A NCAC 2H
.0224 and may result in the assessment of a civil penalty.
If you have questions concerning operator training or examinations for certification, please
contact your local North Carolina Cooperative Extension Service agent or our office.
Examinations have been offered on an on -going basis in many counties throughout the state for
the past several months and will continue to be offered through December 31, 1996.
Thank you for your cooperation. If you have any questions concerning this requirement please
call Beth Buffington or Barry Huneycutt of our staff at 9191733-0026.
Sincerely
A. Preston Howard, Jr., P.E., Director
Division of Water Quality
Enclosure
cc: Wilmington Regional Office
Water Quality Files
P.O. Box 27687, Nf
�y�CRaleigh, North Carolina 27611-7687 An Equal Opportunity/Affirmative Action Employer
Voice 919-715-4100 50% recycled/I Wk post -consumer paper

L1151g3031
D
.REGI STR T I& FORM FCR ANIMAL FEEDLOT OPERATIONS � C 19g�
Department o7 Environment, Health and Natura i Resou
Divisibn of Environmental Management �CR
Water Quality Section��'����,:.
if the animal waste management system for your feedlot operation
i s
designed to serve more than or
equal to 100 head
of cattle,
75
horses, 250 swine, 1,000 sheep, or 30,000 birds thaz
are served
by
a liquid waste system, :hen this
form must be filled
out and mailed
by December 31, 1993 pursuant to
15A NCAC 2H.0217 (c)
in order to
be
deemed permitted by DEM. please
print clearly.
d
Farm Name:
Mailing Addr
Cou
owner (s) Nam
Manaaer (s) N
Lessee Name:
Farm Locacion
milepost& etc
Lat_:•ude/Lonci:nde if known:
direction,
Design capacity of animal waste management system_ (Number and type
of confined animai (s) vz an A 0
3 960
?.verage animal population on the farm (Number and type of animal (s)
=ailed) :2
L�
Year Production BeganAZ
:ASCS Tract No.
.Type o' Waste Management System Used: s�7�
Acres _`Available for Land Application of Waste-:
Owner (s) Signature (s) c DATE
3 r - Oyu
y DATE:

.ram State of North Carolina
Department of Environment,
Health and Natural- Resources 4 • •
Division of Environmental Management
James B. Hunt, Governor
Jonathan B. Howes, Secretary ID FE ri
A. Preston Howard, Jr., P.E., Director
March 23, 1994
Bill McKay
516 Guman Powell Road
Kenansville NC 28349
Dear Mr. McKay:
This is to inform you that your completed registration form required by the recently
modified nondischarge rule has been received by the Division of Environmental Management
(DEM), Water Quality Section.
On December 10, 1992 the Environmental Management Commission adopted a water
quality Wile which governs animal waste management systems. The goal of the rule is for animal
operations to be managed such that animal waste is not discharged to surface waters of the state:
The rule allows animal waste systems to be "deemed permitted" if certain minimum criteria are
met (15A NCAC 2H .0217). By submitting this registration you have met one of the criteria for
being deemed permitted.
We would like to remind you that existing feedlots which meet the size thresholds listed
in the rule, and any new or expanded feedlots constructed between February 1, 1993 and
December 31, 1993 must submit a signed certification form (copy enclosed) to DEM by
December 31. 1997, New or expanded feedlots constructed after December 31, 1993 must
obtain signed certification before animals are stocked- on the farm. Certification of an
approved animal waste management plan can be obtained after the Soil and Water Conservation
Commission adopts rules later this year.
We appreciate you providing us with. this information. If you have any question about
the new nondischarge rule, please contact David Harding at [phone].
Sincerely. -
Steve Tedder, Chief
Water Quality Section
enc:
P.O. Box 29535, Raleigh, North Carorina 27626-0535 Telephone [phone] FAX [phone]
. An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

NOV 190
1EGISTRA.T_ON 70R_M FOR ANIMAL FEEDLOT OPEk,�TIONS
L3rI� `t:nent of Environment, Health and Natural` �esou;rcE.s::=
�----� Division of Environmental Management`.:-
Water Quality Section rcr�� Y-5
�57�Ir nal waste management system for your feedlot operation is
-7 :o serve more than or equal to 100 head of cattle, 75
fwA5 ( 0 swine, 1,000 sheep, or 30,000 birds that are served by
3ste system, then this form must be filled out and mailed
- cv -ueuemver 31 ;- 1993 pursuant to - 15A NCAC 2H.02j (c) -�-_n order to be
deemed permitted by DEM. Please print clearly.
Farm Name:
Mailing Address:
County:
,wne r (s) Name:
Manager (s) Name:
lessee Name:
=r:n Location (Be as 5oecif as
mileoost, etc.) :j)jAnj j
o-ssible: road names, direction,
_at; zude/T ongi tude ,i f ;mown: RbsE, OOZ-O� -Z,Z
Desicn capacity of animal waste management system (Number and type
.._ con__nea hW +tpt�r
,veraae animal population on the farm (Number and type of animal (s)
a aised) hngg5
`_'ear Production Began: l�_ ASCS Tract No.: LI _
Tvpe- of--wast Management System Used:
Acres Available for Land 'Appi 'J ation` of Was ACA E
Owner (s) 'Signature (s) DATE: r
DATE:

.' w. State of North Carolina-�
Department of Environment,
Health and Natural Resources •
Division of Environmental Management
James B. Hunt, Jr., Governor "F1
Jonathan B. Howes,, Secretary
tsa
A. Preston Howard, Jr., P.E., Director
December 9, 1993
Bill McKay
Rt. 1, Box 38B
Kenansville NC 28349
Dear Mr. McKay:
This is to inform you that your completed registration form required by the recently
modified nondischarge rule has been received by the Division of Environmental Management
(DEM), Water Quality Section.
On December 10, 1992 the Environmental Management Commission adopted a water
quality rule which governs animal waste management systems. The goal of the rule is for
animal operations to be managed such that animal waste is not discharged to surface waters
of the state. The rule allows animal waste systems to be "deemed permitted" if certain
minimum criteria are met (15A NCAC 2H .0217). - By submitting this registration you have
met one of the criteria for being deemed permitted.
We would like to remind you that existing feedlots which meet the size thresholds
listed in the rule, and any new or expanded feedlots constructed between February 1, 1993
and December 31, 1993 must submit a signed certification form to DEM by December 31
1997. New or expanded feedlots constructed after December 31, 1993 must obtain signed
certification before animals are stocked on the farm. Certification of an approved animal
waste management plan can be obtained after the Soil and Water Conservation Commission
adopts rules later this year.
We appreciate you providing us with this information. If you have any question about
the new nondischarge rule, please contact David Harding at [phone].
Sincerely,
i
Steve Tedder, Chief
Water Quality Section
P.O. Box 29535. Raleigh, North Carolina 27626-0636 'telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 5M recycled/ 10% post -consumer paper