240107_HISTORICAL_20171231

NUH I H UAHULINA
Department of Environmental Qual

A1,JS 2.4oi©7
NUTRIENT MANAGEMENT PLAN
G rower(s):
Farm Name:
County:
Farm Type:
Farm Capacity:
Storage Structure:
Storage Period:
Application Method:
Cecil Barnhill $ Sons
Six B Farm
Columbus
Feed -Fin
3520
Anaerobic Lagoon
180 days
Irrigation R.x
APR 0 2 zoos
BY:
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied. r
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration. rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
r{tLtivru 1 Ur—NN 1 uvvla
Aquifer Protertion Section Page: 1
MAR 3 0 2003

problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft3, tons, etc.):
3520 animals X 986 gal/animal/year =
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (Ibs):
3520 animals X 2.30 Ibs/animal/year =
3,468,960 gallons
8,096.00 Ibs
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on the crop to be grown,
soil type, and surface application.
Page: 2

Tract
Pull
Soil
Crop
Yield
Ibs N
Acres
Lbs N/Ac
Lbs NT
lbs N
Time to
Field
I Type
I Code
L/Ac
/unit
Residual
I IAc
Required
Apply
i
i 687-1
1
St
B
4.1
50.00
3.67
205.0
752.35
Mar -Oct
1687-1
2
St
B
4.1
50.00
3.24
205.0
664.20
Mar -Oct
1687-1
3
St
B
4.1
50.00
2.88
205.0
590.40
Mar -Oct
1687-1
4
St
B
4.1
50-00
2.41
205.0
494.05
Mar -Oct
1687-2
r5
BuB
B
4.1
50.00
4.33
205.0
887.65
Mar -Oct
1687-2
6
BuB
B
4.1
50.00
4.00
205.0
820.00
Mar -Oct
1687-2.
7
BuB
B
4.1
50.00
4.00
205.0
820.00
Mar -Oct
1687-2
8
BuB
B
4.1
50.00
3.71
205.0
760,55
Mar -Oct
1687-2
9 �'
yFo -
f G
3.0
50.00
2.57
150.0
385.50
ne, S-
1687-4
10
GoA
G
3.2
50.00
1.84
160.0
294.40
F- , S-N
16874
11
GoA
-%,G
3.2
50.00
1.20
160.0
192.00
Jun , -N
1687-4
12
NoB
B
4.6
50.00
2.58
230.0
593.40
Mar -Oct
1687-4
13
NoB
B
4.6
50.00
1.80
230.0
414.00
Mar -Oct
1-4
All
K
50.00
12.20
50.0
610.00
S-April
Total 38.23 8278.50
Available N 8096.00
Difference-182.50
Indicates that this field is being overseeded (i.e. interplanted) or winter annuals follow summer
annuals.
'A negative number reflects the total Ibs of additional nitrogen needed to achieve yields on
acreage listed in chart. A positive number means additional acreage is required to utilize the
nitrogen produced by the farm.
NOTE:
This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definitely interfere
`with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
Page: 3

being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
',time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
The following legend explains the crop codes listed in the table above:
Crop Code Crop
A Barley
B Hybrid Bermudagrass - Grazed
C Hybrid Bermudagrass - Hay
D Corn - Grain
E Com - Silage
F Cotton
G Fescue- Grazed
H Fescue- Hay
I Oats
J Rye
K Small Grain - Grazed
L Small Grain - Hay
M Grain Sorghum
N Wheat
O Soybean
Lbs N utilized / unit yield
1.6 Ibs N / bushel
50 Ibs N / ton
50 Ibs N / ton
1.25 Ibs N / bushel
12 Ibs N / ton
0.12 Ibs N I Ibs lint
50 Ibs N / ton
50 Ibs N / ton
1.3 lbs N / bushel
2.4 Ibs N / bushel
50 Ibs N / acre
50 Ibs N / acre
2.5 Ibs N / cwt
2.4 Ibs N / bushel
4.0 Ibs N / bushel
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 0.36 pounds of plant available nitrogen per animal per year in the
sludge based on the application method listed earlier.
If you remove the sludge every 5 years, you will have approximately 6336.00
Page: 4

pounds of PAN to utilize. Assuming you apply this PAN to hybrid bermudagrass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 21.12 acres of land. If you apply
the sludge to corn at a rate of 125 pounds per acre, you will need 50.69 acres of land.
,Dlease be aware that these are only estimates of the PAN and land needed. Actual requirements
could vary by 25% depending on your sludge waste analysis, soil types, realistic yields, and
applications.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may matte this plan invalid.
The following is provided as a guide for establishing application rates and amounts.
Field
Pull
Soil
Type
Crop
Application Rate
inthr
Application Amount
* inches
1687-1
1
St
BK
0.50
0.95
1687-1
2
St
BK
0.50
0.95
1687-1
3
St
BK
0.50
0.95
1687-1
4
St
BK
0.50
0.95
1687-2
5
BuB
BK
0.60
1.00
1687-2
6
BuB
BK
0.60
1.00
1687-2
7
BuB
BK
0.60
1.00
1687-2
8
Fo
BK
0.50
0.95
1687-2
9
Fo
G
0.50
0.95
1687-4
10
GoA
G
0.50
1.00
1687- 4
11
GoA
G
0.50
1.00
1687- 4
12
NoB
BK
0.50
1.00
1687-4
13
NoB
BK
0.50
1.00
*This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
Page: 5

freeboard except in the event of the 25 year 24 hour storm.
It is the responsiability of the producer and waste applicator to ensure that the spreader equipment
')s operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
Additional Comments:
,�D /, /�f.[i -�,;q ,
Page: 6

NUTRIENT MANAGEMENT PLAN CERTIFICATION
Name of Farm:
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
Itwe understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner:
4
'Signature:
Date
Name of Manager (if different from owner):
Signature:
Name of Technical Specialist:
Affiliation:
T
Signature:
Address:
Please Print
Sonya J. Barber
Harvest Net, Inc.
P.O. Box 32
Council, NC 28434
[phone]
Date
Page: 7

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land
application. Any discharge of waste which reaches surface water is prohibited.
Illegal discharges are subject to the assessment of civil penalities of $10,000 per day
by the Division of Environmental Management for every day the discharge continues.
2. The Field Office must have documentation in the design folder that the producer
either owns or has long term access to adequate land on which to properly apply the
waste. If the producer does not own adequate land to properly dispose of waste, he
shall provide NRCS with a copy of a written agreement (sample enclosed) with a
landowner who is within a reasonable proximity, allowing him/her the use of the land
for waste application for the life expectancy of the production facility. It is the
responsibility of the owner of the facility to secure an update of the Waste Utilization
Plan when there is a change in the operation, increase in the number of animals,
method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed; the Nitrogen needs for
realistic crop yields based on soil type, available moisture, historical data, climate
conditions; and level of management, unless there are regulations, that restrict the
rate of application for other nutrients.
4. Animal waste may be applied to land that has a Resource Management System
(RMS) or an Alternative Conservation System (ACS). If an ACS. is used the soil loss
shall be no greater than 10 tons per acre per year and appropriate filter strips will
be used where runoff leaves the field. These filter strips will be in addition, to
"Buffers" requried by DEM. [See FOTG Standard 393 -- Filter Strips and Standard
390 (Interim) -- Riparian Forest Buffers.]
5. Odors can be reduced by injecting the waste or disking after waste application.
Waste should not be applied when the wind is blowing.
6. When animal waste is to be applied on acres subject to flooding, it will be soil
incorporated on conventionally tilled cropland. When applied to conservaton tilled
crops or grassland, the waste may be broadcast provided the application does not
occur during a season prone to flooding. (see "Weather and Climate in North
Carolina" in the Technical Reference -- Environment file for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
runoff does not occur offsite or to surface waters and in a method which does not
cause drift from the site during application. No ponding should occur in order to
control conditions conducive to odor or flies and provide uniformity of application.
5

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
B. Animal waste shall not be applied to saturated soils, during rainfall events, or when
the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that no
more than 20 to 25 percent of the leaf area is covered by solids.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste nutrient loading rates on these -soils should
be held to a minimum and a suitable winter cover crop planted to take up released
nutrients. Waste shall not be applied more than 30 days prior to planting of the crop
on bare soil.
11. Animal waste shall not be applied closer than 25 feet to surface water. This distance
.may be reduced for waters that are not perennial provided adequate vegetative filter
strips are present. (See Standard 393 -- Filter Strips)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and public right-of-
ways.
15. Animal waste shall not be discharged into surface waters, drainageways or wetlands;
by a discharge or by over -spraying. Animal waste may be applied to prior converted
wetlands provided they have been approved as a land application site by a "technical
specialist". Animal waste should not be applied on grassed waterways that discharge
directly into watercourses, and only then at agronomic rates provided the application
causes no runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc.,
shall not be discharged into the animal waste management system.
17. Lagoons and other uncovered waste containment structures must maintain a
§ maadmum operating level to provide adequate storage for a 25-year, 24-hour storm
r event in addition to the one (1) foot mandatory freeboard.
6

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
18. A protective cover of appropriate vegetation will be establised on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). If needed, special vegetation shall be
provided for these areas and shall be fenced, as necessary, to protect the vegetation.
Vegetation such as trees, shrubs, and other wooded species, etc. are limited to areas
where considered appropriate. Lagoon areas should be kept mowed and accessible.
Lagoon berms and structures should be inspected regularly for evidence of erosion,
leakage, or discharge.
19. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
t 20. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
' basis to prevent breakdowns, leaks, and spills. A regular maintenance checklist
should be kept on site..
7

Attachment B. 1 of 4
North Carolina Agricultural Extension Service
Agri -Waste Management
Biological and Agricultural Engineering North Carolina State University
LIVESTOCK WASTE SAMPLING, ANALYSIS AND CALCULATION
OF LAND APPLICATION RATES
James C. Barker*
I. SAMPLE COLLECTION
A. Semi -Solid Lot Manure
i. Scraped directly from lot into spreader
a. From loaded spreader, collect about 2 lbs. of manure from
different locations using nonmetallic collectors.
ii. From storage
a. Collect about 2 lbs. of manure from under the surface crust
avoiding bedding materials and using nonmetallic collectors.
B. Liquid Manure Slurry
i. Under -slotted -floor pit
a. Extend a 1/2" nonmetallic conduit open on. both ends into manure
to pit floor.
b. Seal upper end of conduit (e.g., by placing a thumb over end of
conduit) trapping manure that has entered lower end, remove and
empty slurry into plastic bucket or nonmetallic container.
c. Take subsamples from 5 or more locations or at least 1 quart.
d. Mix and add about 3/4 pint to nonmetallic sample container.
RECEIVED 1 DENR 1 DWQ
Aquifer Protaminn R-dion Exterior storage basin or tank
MAR 3 0 2009
a. Make sure manure has been well mixed with a liquid manure
chopper -agitator pump or propeller agitator.
*Professor and Extension Sepcialist, Biological and Agi-icultu ral [engineering Department, North Carol ilia Ss ate
University, Raleigh, NC.

Attachment B
2 of 4
b. Take subsamples from about 5 pit locations, from agitator pump
or from manure spreader and place in a plastic bucket.
c. Mix and add 3/4 pint to a nonmetallic sample container .
C. Lagoon Liquid
i. Collect about 3/4 pint of recycled lagoon liquid from inflow pipe to
flush tanks in a nonmetallic sample container.
ii. From lagoon
a. Place a small bottle (1/2 pint or less) on end of 10-15' pole.
b. Extend bottle 10-15' away from edge.
c. Brush away floating scum or debris.
d. Submerge bottle within 1' of liquid surface.
e. Empty into a plastic bucket, repeat about 5 times around lagoon,
mix, and add 3/4 pint to nonmetallic sample container.
D. Broiler or Turkey Litter
i. House litter
a. Visually inspect litter for areas of varying quality, e.g., areas
around feeders and waterers, and estimate percent of floor surface
in each area.
b. Take about 5 litter subsamples at locations proportionate to item
a. E.g., if 20% of litter of similar visual duality is around feeders
and waterers, take 1 subsample there and the other 4 subsamples
from remainder of floor surface.
c. At each location, collect litter from a 6" by 6" area down to earth
Boor and place in a plastic bucket.
d. After 5 subsamples have been added to the bucket, mix, and add
about 2-3 lbs. litter to a nonmetallic sample container such as a 1-
gallon freezer bag and seal.
ii. From stockpile
a. Take subsamples from about 5 locations at least 18" into pile.
b. Mix, add 2-3 lbs. to nonmetallic sample container and seal.

Attachment B
3of4
II. SAMPLE PREPARATION AND TRANSFER
A. Place sample into a expandable container that can be sealed. Rinse residues
from container with clean water but do not use disinfectants, soaps, or treat
in any other way.
B. Pack sample in ice, refrigerate, freeze, or transfer to lab quickly.
C. Hand -delivery is most reliable way of sample transfer.
D. If mailed, protect sample container with packing material such as newspaper,
box or package with wrapping paper, and tape.
E. Commercial sample containers and mailers are also available. Contacts:
i. A&L Eastern Agricultural Lab, Inc.
7621 Whitepine Road
Richmond, VA 23237
Ph: [phone]
ii. Fisher Scientific Co.
3315 Winton Road
Raleigh, NC 27604
Ph: [phone]
iii. Polyfoam° Packers Corp.
2320 S. Foster Avenue
Wheeling, IL 60090
Ph: [phone]
iv. NASCO
901 Janesville Avenue
Fort Atkinson, WI 53538
Ph: [phone]
F. Private analytical labs are available, but sample analyses are costly.
G. The NCDA provides this service for North Carolina residents.
i. Address: North Carolina Department of Agriculture
Agronomic Division
Plant/Waste/Solution Advisory Section
Blue Ridge Road Center
P. O. Box 27647
Raleigh, N. C. 27611
Ph: [phone]
Attn: Dr. Ray Campbell
ii. Forward $4 along with the sample.

Attachment B
4 of 4
iii. Include the following identification information with sample:
a. Livestock species (dairy, swine, turkey, etc.)
b. Livestock usage (swine -nursery, finishing; turkey -breeders,
brooderhouse, grower, number flocks grown on litter; etc.)
c. Waste type (dairy -lot scraped manure, liquid slurry; swine -pit
slurry, lagoon liquid, sludge; broiler -house litter, stockpile
iv. Routine analyses performed on all samples: N, P, K, Ca, Mg, Na,
S, Fe, Mn, Zn, Cu, B
V. Additional analyses performed upon request: DM, Mo, Cd, Ni, Pb

of
I w A rF9 a4�� Michael F. Easley, Governor
OQG /
William G. Ross Jr., Secretary
Coleen H. Sullins, Director
North Carolina Department of Environment and Natural Resources
-�
Division of Water Quality
July 1, 2007
Cecil Barnhill DECEIVED
Six B Farm
PO Box 92 JUL. 0 9 2007
Evergreen, North Carolina, 28438
BY:
Subject: Certificate of Coverage No. AWS240107
Six B Farm
Animal Waste Management System
Columbus County
Dear Mr. Barnhill:
In accordance with your application received on December 29, 2006, we are hereby forwarding to you
this Certificate of Coverage (COC) issued to Cecil Barnhill, authorizing the operation of the subject
animal waste management system in accordance with General Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for the Six B Farm, located in Columbus County, with an animal capacity of no greater
than the following swine annual averages:
Wean to Finish: Feeder to Finish: 3520 Boar/Stud:
Wean to Feeder: Farrow to Wean: Gilts:
Farrow to Finish: Farrow to Feeder:
If this is a Farrow to Wean or Farrow to Feeder operation, there may also be one boar for each 15 sows.
Where boars are unneccessary, they may be replaced by an equivalent number of sows. Any of the sows
may be replaced by gilts at a rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009 and replaces the NPDES
COC issued to this facility with an expiration date of July 1, 2007. You are required to continue
conducting annual surveys of sludge accumulation in all lagoons at your facility; the one-year extension
in Condition 1II.19 does not apply.
Pursuant to this COC, you are authorized and required to operate the system in conformity with the
conditions and limitations as specified in the General Permit, the facility's CAWMP, and this COC. An
adequate system for collecting and maintaining the required monitoring data and operational information
must be established for this facility. Any increase in waste production greater than the certified design
capacity or increase in number of animals authorized by this COC (as provided above) will require a
modification to the CAWMP and this COC and must be completed prior to actual increase in either
wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Enclosed for your convenience is
a package containing the new and revised forms used for record keeping and reporting. Please pav
careful attention to the record keeping and monitoring conditions in this permit.
Wo'rthCarolina
Naturally
Aquifer Protection Section 1636 Mail Service Center Raleigh, NC 27699-1636 Telephone: [phone]
Internet: www.ncwaterquality.org Location: 2728 Capital Boulevard Raleigh, NC 27604 Fax 1: [phone]
Fax 2: [phone]
An Equal Opportunity/Affirmative Acton Employer— 50% Recycled110% Post Consumer Paper Customer Service: [phone]

If your Waste Utilization Plan has been developed based on site -specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Perrnittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey, any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must ' submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility. _
Per 15A NCAC 02T .01 I 1(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100-foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Per 15A NCAC 02T .1306, any containment basin, such as a lagoon or waste storage structure, shall
continue to be subject to the conditions and requirements of the facility's permit until closed to NRCS
standards and the permit is rescinded by the Division.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWN P may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Wilmington Regional Office. The Regional Office
Aquifer Protection staff may be reached at [phone]. If you need additional information
concerning this COC or the General Permit, please contact the Animal Feeding Operations Unit staff at
[phone].
Sincerely,
for Coleen H. Sullins
Enclosures (General Permit AWG100000, Record Keeping and Reporting Package)
cc: (Certificate of Coverage only for all cc's)
Columbus County Health Department
Columbus County Soil and Water Conservation District
Wilmington Regional Office, Aquifer Protection Section
AFO Unit Central Files
Permit File AWS240107

V-�0 7 4-1,- I
C" b
P
s a"I 4: S IA , C-*vt
wu�l� nlmf re Akrcd lD,cpa
DYh,i, GGG,�
A4 OA -e-& yid d 5;' ' : 410'13-/
)n Equipment Field Calibration Form
(mm/dd/yy)
Measured ring size: inches
Is ring size within 0.01" of original manufactured size?
Yes or No_ If not replace ring.
RECEIVED/ DBR / DWO
AQUIFER PROTECTION SECTION
JAN05ZU6
149dinvub
JAN1,40
Pressure Gauge Readings At Pump: psi ,
At Traveler: psi (if applicable)
At Sprinkler/Gun: 6 C> psi
Expected Flow Rate (from manufacturers chart): /4?121 GPM
Measure Flow Rate (from flow meter): GPM
Flow rate variance greater than 10%
Yes No
Expected Wetted Diameter (from the wettable acres determination) : 300 ft.
Measured Wetted Diameter: ,? OS, ft.
Wetted diameter variance greater than 15% &/or measured flow variance greater than
10%: Yes No 1/"If Yes, then contact a technical specialist or irrigation
dealer for assistance, enter work order number:
And/or explain findings:
Calibrator: }
(Signature)
Outside Irrigation Equipment Field Calibration Form.doc Retention Period: 3 years Original 4/1103

el e�5
G G/ /3
pe daX M
if l��s�gt� eh�
Irrigation Equipment Field Calibration Form
Location: /- QG /f —Zf � 2 �V— M 7
Date of Field Calibration: /'� - A'� rQ
(mm/dd/yy)
Flow Meter Serial Number: Xa
Equipment Number: 62
Measured ring size: & op inches
Is ring size within 0.01" of original manufactured size?
Yes oryNo. If not replace ring.
Pressure Gauge Readings At Pump:
At Traveler.
�p psi
L /a psi (if applicable)
At Sprinkler/Gun:_ psi
Expected Flow Rate (from manufacturers chart): T_ ZZz T _ GPM
Measure Flow Rate (from flow meter): 143 GPM
Flow rate variance greater than 10%
Yes No L,----
Expected Wetted Diameter (from the wettable acres determination)
Measured Wetted Diameter: 3 D 4 ft.
'�2 dp�41 3 a'
Wetted diameter variance greater than 15% &/or measured flow variance greater than
10%: Yes No /If Yes, then contact a technical specialist or irrigation
dealer for assistance, enter work order number:
And/or explain findings:
Calibrator: /%f I rCJ _
(Signature)
Outside Irrigation Equipment Field Calibration Form doc Retention Period: 3 years Original 4/1/03

A_N-MAL FACILITY ANN-UAL CERTIFICATION FORM
Certificate of Coverage or Permit Number fV . J4_P 0 g46,oCounty Cd4ecAl but S _ Year 200,7
Facility Frame (as shown. on Certificate of Coverage or Permit)_ _ p'-
r
Operator in Charge for this Facility 2 G, 460 !►h t � � � - - - - Certification r_
Land .application of animal waste as allowed by the above permit occurred daring the past calendar year
YES NO_ If NO, skip Part I and Part II and proceed to the certa hcation- Also, if animal waste
was generated but not land applied, please attach an explanation on how the animml waste was handled.
Parti : Facility Information:
I . Total number of application Fields ❑ or Pulls dslease check the appropriate box) in the Certified Animal
Waste Management Plant (CAWMP): 13 Total Useable Acres approved in the CAWMP
2. Total number of Fields D or Pulls (please check the appropriate box) on which land application
occurred during the year_ 13_ _ Total Acres on which waste was applied 3e.�
3. Total pounds of Plant Available Nitrogen (PAN) applied during the year for all application sites:
4. Total pound of Plant Available Nitrogen (PAN) allowed to be land applied annually by the CAWMP and
the permit:
3. Estimated amount of total manure, litter and process wastewater sold �or given -to other persons and taken
oft site during the year tons ❑.- or gallons CI- (please check the appropriate box)
6. An/nual average number of animals by type at this facility during the previous year:
7. Largest and smallest number of animals by type at this facility at any one time during the previous year_
Largest
Smallest K-
(These numbers are for informational purposes only since the only permit limit on the number of animals
at the facility is the annual average numbers)
8. Faciyity's lategrator if applicable- rsl r .Grp YG-
Part H: Fac4 tty Status:
IF THE ANSWER TO ANY STATEMENT BELOW IS "NO", PLEASE PROVIDE A WRITTEN . --
DESCRIPTION AS TO WHY THE FACILITY WAS NOT CONvIQLLA_-3T, THE DATES OF ANY NON
COMPLIANCE, AND EXPLAIN CORRECTIVE ACTION TAUN OR PROPOSED TO BE TAKEN TO
BR NG THIS FACILITY BACK INTO COWI LLkNI CE.
I . Only animal waste generated at this facility was applied to the permitted sites during � Yes +L No
the past calendar year.
BAR 4I � �00�
AFACF 3-14-03

2. Tile faciliry was operated in such a way that there: was no direct runoff of waste from Yes :-- No
the facility (including the houses, lagooru/storage ponds and the application sites} during
the past calendar year.
I There was no discharge of waste to surface water from this facility during the past 64 Yes ❑ No
calendar year.
4. There was no freeboard violation in any lagoons or storage ponds at this facility during �`i Yes ❑ No
the past calendar year.
5. There was no PAN application to any fields or crops at this facility greater th4n the Yes ❑ No
levels specified in this facility's CAWMP during the past calendar year.
6_ All land application equipment was calibrated at least once. during the past calendar year. IC Yes ❑ No
7. Sludge accumulation in all lagoons did not exceed the volume for which the lagoon Yes ❑ No
was designed or reduce the lagoon's minimum treatrnent volume to less than the volume
for which the lagoon was designed.
8. A co ygof the Annual Sludge Survey-Porm fo this facility is attached to this Certification. ❑ Yes 9 No
9 5 An�ni,>� sYoils sana ys s� were performed on eeach�fiel�rV=i*N= al waste during the V Yes ❑ No
past calendar year.
10. Soil pH was maintained as specified in the permit during the past calendar Year? El Yes 5f No
• m ,e.7. 6r ��ly s S�Q h a5 "" � -If jr, o d R
l 1. All required mote ring and reporting was p or dd m accor e with thZ facility's 62 Yes ❑ No
permit during the past calendar year.
12. All operations and maintenance requirements in the permit were -complied with during Yes ❑ No
the past calendar year or, in the case of a deviatioa., prior authorization was received
from the Division of Water Quality.
13. Crops as specified in the CAWNT were maintained during the past calendar year on all Yes ❑ No
sites receiving animal waste and the crops grown were removed in accordance with
the facility's permit
14. All buffer requirements as specified on the permit• and the eAV'NT for this facility were # Yes ❑ No
maintained during each application of animal waste during the past calendar year.
"I certify under penalty of law that this document and all attachments were prepared under my direction or
supervision in accordance A ith a system designed to assure that qualified personnel properly gather and
evaluate The information submitted. Based on my inquiry o€the person or persons who manage the system, or
those persons directly responsible for gathering the information, the information submitted is, to the best of
my knowledge and belief, true, accurate, and complete. I am aware that there are significant penalties for
submitting false information, including the possibility of fines and imprisonment for knowing violations."
or print)
mature of Operator in Ch
different from Permittee)
Date
Date
AFACF 3-14-03 1 ?

Appendix 1. Lagoon Sludge Survey Form
A. Farm Permit or DWQ Identification Number
B. Lagoon Identification 15x , wl ^
C. Person(s) Taking Measurements n `
D. Date of Measurements --3 _� y
E. Methods/Devices Used for Measurement of:
a. Distance from the lagoon liquid surface to the top of the sludge laver:
b. Distanpf from the�rtgoon liquid surface to the bottom (soil) of the lagoon:
JAJ
C ►-- _
c. Thickness of the scud a layer if making a direct measurement with "core sampler":
2q- 107
RECEIVED
APR 2 g 20P
WATER QUALITY SECTION
Non-Discharya Corr, , ce Eri.
F. Lagoon Surface Area (using dimensions at inside top of bank): (acres)
(Draw a sketch of the lagoon on a separate sheet, list dimensions, and calculate surface area.)
G. Estimate number of sampling points: e
a. Less than 1.33 acres: Use 8 points J P 3
b. If more than 1.33 acres, a�a acres x 6 = with maximum of 24.
(Using sketch and dimensions, develop a uniform grid that has the same number of intersections as the
estimated number ofsampling points needed. Number the intersection points on the lagoon grid so that data
recorded at each can be easily matched.)
H. Conduct sludge survey and record data on "Sludge Survey Data Sheet" (Appendix 2).
1. At the time of the sludge survey, also measure the distance from the Maximum Liquid Level
to the Present Liquid Level (measure at the lagoon gauge pole):
J. Determine the distance from the Maximum Liquid Level to the Minintum Liquid Level
(use lagoon management plan or other lagoon records):
K. Calculate the distance from the present liquid surface level to the Minimum Liquid Level
(Item J minus Item 1, assuming the present liquid level is below the Maximum Liquid Level):
L. Record from the Sludge Survey Data Sheet the distance from the present liquid surface level (�
to the lagoon bottom (average for all the measurement points):
M. Record from the Sludge Survey Data Sheet the distance from the present liquid surface level
-to the top of the sludge laver (average for all the measurement points): <Q
N. Record from the Sludge Survey Data Sheet the average thickness of the sludge laver: 1
U. Calculate the thickness of the existing Liquid Treatment Zone (Item M minus item K):�-�—
(Notc: If Item O is less than 4 feet, a sludge removal and utilization plan may he required by
NX1 DWQ. Sec your specific permit or contact )WO for more information.)
I'. Proceed to the Sludge Volume Worksheet if you desire to calculate sludge volume tier a rectangular -
shaped lagoon with uniform side slopes.
=� Completed by-.ccDate: 3 ^ G
Prita a Signature
14

Appendix 2. Sludge Survey Data Sheet*
L .go T tification:
Sludge Survey Data Sheet
Completed by:�OL_f %4 r �% / Date: , -rimer Q L
Print Name Signature
(A)
Grid
Point
No.
(g) •
Distance from liquid surface
to top of stud a
(C)
Distance from liquid surface
to lagoon bottom soil
(C) minus (8)
Thickness of sludge
la er
Ft. & in.
Ft. tenths .
Ft. & in.
Ft, tenths
Ft. & in.
Ft. (tenths
2
e. A
3
f.
4
5
6
. S
-• ao
73
j
8
,
y.-.
9
10
11
O
— ----
_j�_I
/
12
13
.DO
i.v0
1
14
r
15
16
17
18
19
20
21
22
23
24
L:-
'" 411 Grid Puints and corrss ondin stud e laver thicknesses must be shown on a sketch gtlyehed to this
Sludge Survey Data Sheet.
See Appendix 4 for conversion fi-om inches to tenths of a foot.
15

jai
6'
­517
,a

i
G. ¢
r
¢, 9 Z,65
Materials for making a Sludge Measuring Device
I — Bottom or top of a five (5) gallon bucket
I — Closet flange (3"x4")
1 — YV" PVC adapter
I — 2"xl" PVC adapter
1 -- Section of 1" PVC pipe (SCH 40)
4 — Stainless steel bolts and nuts
PVC glue
For a copy of the publication "Slud'ge Survey Methods for Anaerobic Lagoons", go to the web site listed
here: www.bae.ncsii.edii/i)ronanis/extension/manure/sludge-survey/sliidgesiirvey.htm

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
Michael F. Easley, Governor
William G. Ross Jr., Secretary
Gregory J. Thorpe, Ph.D., Acting Director
February 8, 2002
Mr. Cecil Barnhill
Six B Farm
P O Box 92
Evergreen, NC 28438
A
• •
NCDENR
NORTH CAROI,INA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Certificate of Coverage No. AWS240107
Six B Farm
Swine Waste Collection, Treatment,
Storage and Application System
Columbus County
Dear Mr. Barnhill:
In accordance with your permit application received on August 25, 1998 and additional
information received on November 5, 1998, October 26, 2000, July 17, 2001 and November 19, 2001,
we are forwarding this Certificate of Coverage (COC) issued to Mr. Cecil Barnhill, authorizing the
operation of the subject animal waste collection, treatment, storage and land application system in
accordance with General Permit AWG100000. This approval shall consist of the operation of this
system including, but not limited to, the management of animal waste from the Six B Farm, located in
Columbus County, with an animal capacity of no greater than 3,520 Feeder to Finish swine animals and
the application to land as specified in your most current Certified Animal Waste Management Plan
(CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations
as specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General
Permit or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS
143-215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
Upon notification by the Division of this COC's expiration, you shall apply_ for its renewal_ This
request shall be made within 30 days of notification by the Division.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

Certificate of Coverage AWS240107
Six B Farm
Page 2
This COC is not automatically transferable. A name/ownership change application must be
submitted to the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the
right to apply for an individual non -discharge permit by contacting the engineer listed below for
information on this process. Unless such a request is made within 30 days, this COC shall be final and
binding.
The subject farm is located in the Wilmington Regional Office. The Regional Office Water
Quality Staff may be reached at [phone]. If you need additional information concerning this
COC or the General Permit, please contact Marie Doklovic at [phone] ext. 371.
6
Gregory J. Thorpe, Ph.D.
cc. (Certificate of Coverage only for all cc's except Regional Office)
Columbus County Health Department
Wilmington Regional Office, Water Quality Section
Columbus County Soil and Water Conservation District
Ms. Sonya Barbour, Harvest Net, Inc. (PO Box 32, Council, NC 28434)
Water Quality Central Files
NDPU Files
t

Notification of Change of Ownership
Animal Waste Management. Facility
(Please type or print all information that does not require a signature)
In accordance with the requirements of 15A NCAC 2H .0217(a)(19HXxii) this farm is official noiificatibn to the Division of
Water Quality (DWQ) of the transfer of ownership of an Animal Waste Management Fucility. This furitt n)ust be submitted to
DWQ no later than 60 days following the transfer of ownership.
Gramm] m] or atiot :
Name of Farm: 13cu rie 1 Far Ws S Xv%c, _ } Facility No: 2M - 1 Ori
Previous Owner(s) N
New Owner(s) Name
Nlailine Address:-N
Farm Location:
Phone No: o- 'lt 39 -O
Phone No: 910
Latitude and Longitude: iY� i ! e,£Q����r county:L��;,fw+�s
Please attach a copy of a county road uiap with lwatiun identified atld describe helow (Be specific: road names, directions.
Il1llCpd)SL, etd:-}: _t?'ew. �yd �sss� Ta C� S' ° -L
`•
If
Operation Descriotion:
Type of 5irilie No. of .irti duds
J Wean to Feeder
fffeeder to Finish r 5:iC7
;1 F:uITOW to Wean
Farrow to Feeder
ri Farro.v to Finish
O Gilts
❑ Boars
Type of Poultry No- of Aniuduls
Cs Layer
0 Non- Layer
7Trpe of Beef No. of Ajiialuls
0 arcmd
O Feeders
-.I Stockers
Other Ttipe of Livestock
Type of Dain-
J Milking
O Dry
* Heifers
iD Calves
No. of Animals
Number of Animals:
Acreage Available for Application: % Required Acreage:
Number of Lagoons / Storage Ponds: Total Capacity: Cubic Feet (ft3)
sfim■#ss#**sass##*1ss#######ss�####s##########ass#s####iss####s#is############s#######
O► her / iManuger agreement "
I (dc•C) VCI'ily that all the above information is correct and will be updated upon changing. I (we) understand the operation and,
1l1a11liClla11CC I)1`UCCdl111C.S C.ltah11S11Cd ill die alll)ruwed altillIA ►►aSte I11,HLILC411C1)t plan for the farm nallied above and will
inulllvulellt Ihese pCocedures. I (we) kilow that ally expar►;ion to the exiitille design c:apacily of the waste to atinc:lit and suliaw,c
sy;u:nu or tonsuuction of new facilities Will rcdluir,: a rlew cerlilicalion in bx submitted tU the DWQ before the new animals are
SLOckedf. l (we) uncier;land that there must be no discharge of animal waste from the storage or application system Eu surface
waters of the state either directly througha man-made conveyance or from a storm event less severe than the 25-year. 24-hUur
sturni and there: enusd not be run-ofl- front the application of animal waste. t (we) understand that run -oft of pollutants front
plunging and heavy use areas must be minimized wing technical standards developed by the Natural Resources Conservation
Service. The approved plan will be filed at the farm and at the office of d w lilcal Soil and Water Conservation District- I (we)
know that any modfilication must be approved by a technical specialist and submitted to the Soil and Water Conservation
Districl prior to implenicniatiun. A chaiwc in land ownership require; written notif ,ration to DWQ or a new certification (if
the approved plan is changed) within 60 days of a title transfer.
Name of New Land Owner .
Signature
Nance of ?Vlanager (if different from owner):
Signature:
Please sign and return this form to:
Date:���ls�a%
Date
NC Division of ►Vater Quality �����D
Non -Discharge CDatphance & EnforcemeR ���---++++
1617.1,11ail Service Center OCT 2 2 2UUI
Raicigh, NC 27699-1617
::. T F OU.L� Ty SEf'ial o< i. 2tltl0

r..
State.of North Carolina
Department of Environment and Natural Resoure&44 U e ,
Division of Water
Non -Discharge Permit Application cati n Form uality �,� �g�Gy� N
(THIS FORM MAYBE PHTOCOPIED FOR USE AS AN ORIGINA ') 51998
General Permit - Existing Liquid Animal Waste �><ons
The following questions have been completed utilizing information on file with the Divas Please
review the information for completeness and make any corrections which are appropriate. If a
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
1. GENERAL INFORMATION:
I.1 Facility Name: Barnes Farms Inc.
1.2 Print Land Owner's name: Ricky Barnes
1.3 Mailing address: 3965 Kings Cross Rd
City, State: Lumberton NC
Telephone Number (include area code): 910-739-0158
1.4 County where facility is located: Columbus
Zip: 28358
1.5 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a
copy of a county road map with the location of the farm identified): On south side of SR I003before you reach SR 1002.
1.6 Print Farm Manager's name (if different from Land Owner): C e C. R i2.p1 h I
1.7 Lessee's I Integrator's name (if applicable; please circle which type is listed): Carroll's Foods Inc
1.8 Date Facility Originally Began Operation:
1.9 Date(s) of Facility Expansion(s) (if applicable): Alm- AAJZ
D
2. OPERATION INFORMATION:
2.1 Facility No.: 24� (county number); 107 _ (facility nurr
2.2 Operation Description: Swine operation
Fi-ede-r to Finish
3520- Certified Design Capacity
Is the above information correct? yes; no. If no, correct below using the design capacity of the facility
The "No. of Animals" should be them rmnm number or which the waste management structures were designed.
Type of Swine No. of Animals Type of Poultry No. of Animals jyj�Le of Cattle No. of Animals
Wean to Feeder -Layer Dairy
S, ,
Feeder to Finish_ Non -Layer Beef
Farrow to Wean (# sow) Turkey
Farrow to Feeder (# sow)
Farrow to Finish (# sow)
Other Type of Livestock on the farm: Qom% J� No. of Animals: in
—r-- -- -■■.l-. r T1 enoAno Vo. S.1 ofA 7d- IR7

2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): 27 ; Required Acreage (as listed in the AWMP): -4"r
2.4 Number of lagoons/ storage ponds (circle which is applicable): I _
2.5 Are subsurface drains present within I of any of the application fields? YES or ED (please circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES or 4g (please circle one)
2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, NRCS Standards, etc.) (Swine Only)
E or NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited? 2 1 o 9S�
What was the date that this facility's land application areas were sited?! d�9
3. REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
_item.
_.
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit
application for animal waste operations.
The CAWMP must include the following components:
3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application.
3.3.4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application field.
3.3.9 The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.3.10 A site schematic.
3.3.11 Emergency Action Plan.
3.3.12 Insect Control Checklist with chosen best management practices noted.
3.3.13 Odor Control Checklist with chosen best management practices noted.
3.3.14 Mortality Control Checklist with the selected -method noted.
3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility.
3.3.16 Operation and Maintenance Plan.
If your CAWMP includes any components not shown on this list, please include the
additional components with your submittal
Applicants Initials
- /e00� - O
00<0, O Q
FORM! AWO-G-F r%/2R/9R Pope 2 of 4 24 - 107

Facility Number: 24 - 107
Facility Naive: Barnes Farms Inc_
4. APPLICANT'S CERTIFICATION:
4,- . 'CS 1%
"Ohar9e A.m., .
q
Owners naive listed in question 1.2), attest that
this application for AAGkIC' ¢,�jyl�_�� . (Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned to me as incomplete.
5. MANAGER'S CERTIFICATION: (complete only if different from the Land Owner)
(Manager's name listed in question 1.6), attest that this
application for _ - - `. _�.-- - `" Z 6 4 'Ne1 q jC,a,?_&,S ��,?£ - (Facility name listed in question 1. i)
has been reviewed sy me and is acc ;�tete to the best of my knowledge. I understand that if all required parts of this
application are not-c6m-pleted aridtirat if-alireq- dire- i supp t�Cguuortnation an at c%dients are not included, this application
package will be returned as incomplete.: A .,
Signature
Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION 1�:
NON -DISCHARGE PERMITTING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
� ran mdo V--- Z nir d 7A - 1111

` Ulf' f Ise
L.v,
Animal Waste Management Plan Certification
(Please tape or print all information that does not require a signature)
lExisting. or t' New -or Expanded (please circle one) -- _ I
General
Name of Farm: Rarnps Farmst Facility No:
Owners) Name: Highy Rarnes Phone No: (910) 7 3 9 — 015 8
Mailing Address: 9„f5KinQs, Cross R - T.ttmhortony NC 28-158
Farm Location: County Farm is located in: Columbus
Latitude and Longitude: 34 2 5 _ 0 5/, -E _ 9 0
PIease attach a copy of a county road map with location identified and describe below (Be specific: road
names, directions, milepost, etc.): South Of RR t rt n 1 & W o S t .%f LIUW din �.
Operation Description:
7tpe of Swine No. of Animals
7 Wean to Feeder
7L Feeder to Finish 3520
i Farrow to Wean
Z! Farrow to Feeder
3 Farrow to Finish
Type of Poultry- No. ofrinimals Tri7e of Cattle No. of animals
Laver 3 Dairy
0 Pullets :3 Beef
Other Type of Livestock umber of Animals:
Fspandint Operaaon Only _ _
Previous Design Capacity: Additioital Desi rt Ca aci '
Design Capacity: -
Acreage Available for Application: 27 Required Acreage: 17
Number of Lagoons / Storage Ponds : 1 Total Capacity: 6 94 5 29 Cubic Feet (ft3)
Are subsurface drains present on the farm: YES or NO (please circle one)
If YES: are subsurface drains present in the area of the LAGOON or SPRAT' FIELD (please circle one)
Owner I Manager A greernent
°'z all the above information is correct and will be updated upon changing. I (we) understand the operation and
maintenance procedures established in the approved animal waste management plan for the farm named above and will
implement these procedures. I (we) know that any expansion to the existing design capacity of the waste treatment and
storage system or construction of new facilities will require a new certification to be submitted to the Division of
Environmental Manasmment before the new animals are stocked. I (we) understand that there must be no discharge of animal
waste from the storage or application system to surface waters of the state tither directly through a man-made conveyance or
from a storm event less severe than the 25-Fear. 24-hour storm and there must not be run-off from the application of animal
waste_ I (we) understand that run-off of pollutants from lounging and heavy use area_ must be minimized using technical
standards developed by the Natural Resources Conservation Service. The approved placer will be filed at the farm and at the
order of the local Soil and Water Conservation District. i txvct know that any modification must be approved.by a technic)
spezialist and submitted to the SOIL and Water Conserv3tion District prior to implementation. A change to land ownership
require: written notification to DEM or a new ceniftcation of the acproved plan is chance _Ji within 60 days of a title transfer.
Nance of Land Owner : -Aas,rw-_
Signature:
Date:_1 50 — ? Z
Name of Mina -Len If „if ei _-nt frcm owner 1:

Technical Specialist Certification
LAs a tcchntcal specialist designated by the North Carolina Soil and Ovate. Conservation Co.nrrvssion pursuant to 15A
NCAC 6F .0005. 1 certifv that the animal waste management system for the farm named above has an artimal waste
management pian that meets or exceeds standards and specifications of the Division of Environmental Management (DE.%1)
as spc_ified in ISa NCAC 2H.0217 and the USDA Natural Resources Conservation Service (\RCS) and/or the North
Carolina Soil and Water Conservation Commission pursuant to 15A \CAC 2H.0217 and ISA NCAC 6F.0001-.0005. The
following elemcnts are included in the plan as applicable. While each cucgory designates a ;echnical specialist who may
sign each Certification 6D. St. UT-P. RC. I), the technical specialist should on!� certify parts for which they are techoicaily
COmnetent. -
II. Certi
f'eation o, f Desib yz
A) Collection, Storage, TrettmenLaystem
Check the appropriate box
.J Existins acility without retrofit (SD or WUP)
Storage volume is adequate for operation capacity; storage capability consistent with waste utilization
requirements.
�t \e :L° ex a ded or retr fitted facility (SD)
,animal waste storage and treatment structures, such as but not limited to collection systems, lagoons and ponds,
have been designed to meet or exceed the minimum standards and svc6ficaticns.
Name of Technical Specialist (Please Print): Don
Affiliation: USDA, Natural Resources
Address( '.A v): 112 West Smith Street hone tio.:
Signature: Date: /-?6-27
B) Land ApWication Site (I LTP)'
The plan provides for minimum separations (buffers); adequate amount of land for waste utilization; chosen crop is
suitable for waste management; hydraulic and nutrient loading rates.
Name of Technical Specialist (Please Print): Donna G. Register, D.C.
Affiliation: USDA, Natural RPC-]t---- wRr+r+se vat -lee --se ryiee
Address (Age ncy): 112 West Smith Street, Whiteville Phone No.:(910 )642-2348
Signature:_ .'q &. �&Q� Date: D
C) Runoff ontrols from Exterior Lo
Check rite appropriate box
J Facility- without exterior lots (SD or W-UP or RC)
This facihiv does not contain am• exterior lots_
J F1,�'!lity kviih exterior lots (RC)
NIc:hods ;o r6rtnuzf the run off of pollutants from louncing and use ucas h:ne b�cn dtsi._ocd in
a.:_-rjanzc with :c_hntcal ctaniard.ido%c!c2eJ b% NRCS. `
\�n�c of Tuc! ttical Spe6ilist Pr: ,i

D)..�1 rlicatirin and Handling E ui men(
Check, the opprnpriure box
0 Eel:tin; or err+andin;.iacilit� u ith existirte �t'acte applicari�n e lement (W-UP or I)
:animal %xastc application equipment spe=:itcd in the plan has been either field calibrated or evaluated in
ac_ordance with existing design charts and tables and is able to apply waste as necessary to accommodate the
Waite management plan: (.existing application equipment can cover the area required by the plan at rates not to
exceed either the spe:ified hydraulic or nutrient loading rates. a schedule for timing of applications has been
established: required buffers can be maintained and calibration and adjustment guidance are contained as part of
the plan).
v Net'. expanded. or existing_ facility without existing u-aste application a ;uipment for orav
irri ratio . (I)
Animal waste application equipment specified in the plan has been designed to apply waste as necessary' to
accommodate the waste management plan: (proposed application equipment can cover the area required by the
plan at rates not to exceed either the specified hydraulic or out:tent loading :aces: a schedule for timing of
applications has been established; required buffers can be maintained; calibration and adiustment guidance are
contained as part of the plan).
New, expanded. or existing aci 'n' without exisJrt; waste arpji936on eouipmenl for land
spreading. not using spray i '.-a ion. (ur"UP or 1)
Animal waste application equipment specified in the plan has been, selected to apply waste as necessary to
accommodate the waste management plan. (proposed application equipment can cover the area required by the
plan at rates not to exceed either the specified hydraulic or nutrient loading rates; a schedule for timing of
applicatic :s has been established: required buffers can be maintained; calibration and adiustment guidance are
contained as part of the plan).
Name of Technical Specialist (Please Print): Donna G. Register
Affiliation: USDA, Natural Resources Conservation Service
Address(Age y): 112 West Smith Street Whiteville Nthone No.: 910 642-234 8
Signature:2 40- Daze:_ 1- 3G 4 7
E)
I WUP RC or 1
The waste management plats for this facility includes a Waste Management Odor Control Checklist, an Insect Control
Checklist. a atonality Management Checklist and an Emergency Action Plan. Sources of both odors and insects
have been evaluated with respect to this site and Best Management Practices to Minimize Odors and Best
-1anagement Practices to Control Insects have been selected ane included in the waste manaaernent plan. Both the
Mortaliiv \lanagement Plan and the Emergency Action Plan are complem and can be implemented by this facility.
Name of Technical Specialist (Please Print): Donna G. Register
Affiliation: USDA, Natural Resources Conservation Service
Address(Aeency): 112 West Smith Street, Whiteville, bone No.: (910) 642--2348
St. -nature: woe Date: l'" D
F) Written Notice of Nei.- or Expanding Swine -Farm
The follouinz signature block is only to he used for new or expanding seine farms that begin construction after June
21. 1996. If the facility -.%as built before June 21. 1996. %A -hen was it constructed or last expanded
1 ogre, cratiy hat I tu.) late arre:ne!ed toron.tx! by .�rricd mail all 1:!io!n!n rr�penv otcne.s and ail ,rope.,.• ovine s
who own ^rc;crt� lo,-ad :]c:os; a zu.Diic road stre-!.:r �tchxva from this ne'a at czpan^ir,� S%V'r far-(. TnC notice ua; in
co!n;•hsncr a tat !h: r- n!z & NCGS 10o-505 A of the neric_ inn a'is, of the �rCrcnl' Otc-r-S ao!!ttcd is
att_.hrd.
\ante: of l__tnd 0%%nee :
i�nJture:

t-.
III. Certification of Installation
A) Collection. Storage. TreatmentTnstallation
expanded or retrofitted faciLLty (SI)
Animal waste storage and treatment structures. such as but not limited to lagoons and ponds. have besrt installed in
accordance with the approved plan to meet or exceed the minimum standards and specifications.
For existing facilities without retrofits, no certification is necessary.
Name of Technical Specialist (Please Print):, Donna__G._ Register
Affiliation: USDA, Natural Resources Conservation Service
Address(Age v): 112 West Smith Street, Whiteville NtehoneNo.:f_10)642,-234g
Signature: -62LZD Date:. r —J6 -5 7
B} Land Application Site (NVUP)
Check the appropriate box
,G The cropping system is in place on all land as specified in the animal waste management plan_
Sprigged Summer of 1996.
I Conditional Approval: all required land as specified in the plan is cleared for planting; the cropping system
as specified in the waste utilization plan has not been established and the owner has comrnitte3 to establish the
vegetation as specified in the plan by (month/day/year): the proposed cover crop is appropriate
for compliance with the wasteutilization plan.
❑ Also check this box if appropriate
if the cropping system as specified in the plan can not be established on newly cleared laud within 30 days
of this certification. the owner has committed to establish an interim -crop for erosion-cdotrol;
Name of Technical Specialist (Please Print): Donna G. Register
Affiliation: USDA, Natural Resources Conservation Service
Address(Agency): 112 West Smith Street, Whiteville, NCPhone No : (9'10) 642-2348
Signature:,
This following signature block is only to be used when the box for conditional approval in III. B
above has been checked.
I (we) cenifY that I (we) have committed to establish the cropping system as specified in my (our) waste utilization plan, and
if appropriate to establish the interim crop for erosion control. and will submit to DEM a verification of completion from a
Technica! Specialist within ) c calendar days following the -date specified in the conditional certification. I (we) realize that
failure to submit this verification is a Violation of the waste management plan and will subject me (us) to an enforc--meat
action from DBI
Name of Land Owner:
Signature:
Nacre of from o\%-ner::
Si -nature:
Date:
Date:

C) Runoff Controls from Exterior LnLS (RC)
Facility Sri h extc-ior ICU
Methods to runirnize the run off of polluunts from lounging and heavy use azea_s have been installed as specified
in the plan.
For facilities without exterior lots, no certification is necessarv.
,Name of Technical Specialist (Please Print):
Affiliation:
Address(Agency):
Signature:
hone No
Date:
D) Application and andlina Eguipment Installation (WUP or I)
Greek the approprime block
t�t Animal waste application and handling equipment specified in the plan is on siu and readyfor use; cal ibratioo
and adjustment materials have been provided to the owners and ate contained as par. of tale plan.
J Animal waste application and handling equipment specified in the plan has not been instailed but the owner
has proposed leasing or third party application and has provided a signed contract: equipment specified in the
contract aerccs with the requirements of the plan; required buffers can be maintained. calibration and
adjustment guidance have been provided to the owners and are contained as par, of the plan-
2 Conditional appros'al: Animal waste application and handling equipment specified in the plan has beers
purchased and will be on site and installed by (monthldav/vear): there is adequate storage to
hold the waste until the equipment is installed and until the waste can be land applied in accordance with the
cropping system contained in the plan: and calibration and adjustment guidance have been provided to the
owners and are contained as part of the plan.
Name of Technical Specialist (Please Print):_ Donna G._-Register _
Affiliation: USDA, Natural Resources Conservation Service
1 1 1 Wa M4=f cmi t•h ct•rnol- Whit-niri 1 1 c Mr.
Address(AQenc
Signacure:
eNo.: [phone]
/-30 -S 7
The following signature block is only to be used when the box for conditional approval in III D
above has been checked.
I (we) certifx, that I (we; have committed to purchase the animal waste application and handling equipment as
specified in my four) waste management plan and will submit to DEM a verification of delivery and installation
from a Technical Specialist within 15 calendar days following the date specified in the conditional certification. I
(we) realize that failure to submit this verification is a violation of the waste management plan and ►%•ifl subject me
(us) to an enforcement action from DELI.
?1"2me of Land Owner :
Signature: Date:
,Nance of -ManageriI[ diff:.*eni from on-ner):
Si;nature: Date:
E) Odor Cnnirnl. Insect Cnntrol and N(ortafity Mana,,enient 1SD. S1. tiVUR RC or l)
Nie O'is to cor,:.A odlors and .. -_e--!s is to (h, P!;;;1 h-„ .^t: ] -ind 1rc e.-iiuonal. T.ie
in the: J'»:7 aS ,lip)C-]3`... :` il: .a111C3t
F!. <t Prin, _ i unrva._G.._-RegJ stt_L-�---
:.:.i+� USDA Natu.ral__Re-s.atlrs__. Onset.uationis_t-.��vice-_._�..0
'�.=-=._ 112 West rn-1 ree.t Whiteville_N-C.:':. r,. `. 9iQ-642-.2348
AL

I
I
L
J wr wm U`a
N p $
O a
I
0-0. "�
10
000 w-

NUTRIENT MANAGEMENT PLAN
Grower(s):
Farm Name:
County:
Farm Type:
Farm Capacity:
Storage Structure:
Storage Period:
Application Method:
Cecil Bamhill & Sons
Six B Farm
Columbus
Feed -Fin
3520
Anaerobic Lagoon
180 days
Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste util¢ation plan uses nitrogen as the limiting nutrient Waste should be analyzed
before each application cycle. Annual sod tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maAmize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner.
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter slips are established..
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
Page: 1

problems_
6. To ma)dmize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be fle)dble so as to accommodate ganging waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with_ 15A NCAC
21-1.0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft3, tons, etc.):
3520 animals X 986 gal/animal/year =
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (Ibs):
3520 animals X 2.30 Ibs/animaltyear =
3,468,960 gallons
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on the crop to be grown,
soil type, and surface application.
Page: 2

Tract
Field
Pull
Sob
Type
Crop
Code
Yield
IAc
On N
lunid
Acres
Lbs NIAG
Residual
Lbs N
IAc
lbs N
Regtdred
Time to
Apply
16871
1
St
B
4.1
50.00
3.67
205.0
752.35
Mar -Oct
1687-1
2
St
B
4.1
50.00
3.24
205.0
664.20
Mar -Oct
1687-1
3
St
B
4.1
50.00
2.88
205.0
590.40
Mar -Oct
1687-1
4
St
B
4.1
50.00
Z41
205.0
494.05
Mar -Oct
1687-2
5
BuB
B
4.1
50.00
4.33
205.0
887.65
Nlar-Oct
1687-2
6
BuB
B
4.1
50.00
4.00
205.0
820.00
Mar -Oct
1687-2
7
BuB
B
4.1
50.00
4.00
205.0
820.00
Mar -Oct
1687-2
8
BUB
B
4.1
50.00
3.71
205.0
760.55
Mar -Oct
1687-2
9
Fo
G
3.0
50.00
2-57
150.0
385.50
F-June. S-N
1687
10
GoA
G
3.2
50.00
1.84
160.0
294.40
F-June, S-N
1687
11
GoA
G
3.2
50.00 "
1.20
160.0
192.00
F-June, S-N
1687
12
NOB
B
4.6
50.00
2-58
230.0
593.40
Mar -Oct
16874
13
NoB
B
4.6
50.00
1.80
230.0
414.00
Mar -"Oct
1-4
AN
K
50.00
1220
50.0
610.00
S�"
Total 38.23 8278.50
Available N 8096.00
*Difference-182.50
-vindicates that this field is being overseeded (l.e. interplanted) or winter annuals follow summer
annuals.
*A negative number reflects the total lbs of additional nitrogen needed to achieve yields on
acreage listed in chart. A positive number means additional acreage is required to utilize the
nitrogen produced by the farm.
NOTE:
This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will de%nateiy interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
Page: 3

being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
The following legend explains the crop codes listed in the table above:
Crop Code Cron
A Barley
B Hybrid Bermudagrass - Grazed
C Hybrid Bermudagrass - Hay
D Com - Grain
E Com - Silage
F Cotton
G Fescue - Grazed
H Fescue - Hay
I Oats
J Rye
K Small Grain - Grazed
L Small Grain - Hay
M Grain Sorghum
N Wheat
O Soybean
Lbs N utilized / unit ydeld
1.6 lbs N / bushel
50 lbs N I ton
50 lbs N 1 ton
1.25 lbs-N [bushel
12 lbs N / ton
0.12 lbs N / lbs lint
50 lbs N I ton
50 lbs; N 1 ton
1.3 lbs N / bushel
2.4 lbs N 1 bushel
50 lbs N 1 acre
50 lbs N / acre
2.5 lbs N I cwt
2.4 lbs N / bushel
4.0 lbs N I bushel
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over app5cation of nutrients or other elements. Your production facility will produce
approximately 0.36 pounds of plant available nitrogen per animal per year in the
sludge based on the application method listed earlier.
If you remove the sludge every 5 years, you will have approximately
6336.00
Page: 4

4 _ .
pounds of PAN to utilize. Assuming you apply this PAN to hybrid bermudagrass hayland at the
rate of 300 pounds of nitrogen per acre, you wHI need 21.12 acres of land. If you apply
the sludge to corn at a rate of 125 pounds per acre, you will need 50.69 acres of land.
Please be aware that these are only estimates of the PAN and land needed. Actual requirements
could vary by 25% depending on your sludge waste analysis, soil types, realistic yields, and
applications.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
The following is provided as a guide for establishing application rates and amounts.
Feld
Pull
Sal
Typ2
Crop
Appkafim Rate
it ft
Appficafion Anxxmt
* inches
16874
1
St
BK
0.50
0.95
1687-1
2
St
BK
0.50
0.95
1687-1
3
St
BK
0.50
0.95
1697--1
A
St
BK
0.50
0.95
1687-2
5
BUS
BK
0.60
1.00
1687-2
6
BuB
BK
0.60
1.00
1687-2
7
BuB
BK
0.60
1.00
1687-2
8
Fo
BK
0.50
0.95
1687-2
9
Fo
G
0.50
0.95
16874
10
GoA
G
0.50
1.00
16874
11
GoA
G
0.50
1.00
16874
12
NoB
BK
0.50
1.00
16874
13
NoB
BK
0.50
1.00
"This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application' "
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
Page: 5

freeboard except in the event of the 25 year 24 hour storm.
It is the responsiability of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
Additional Comments:
Page: 6

NUTRIENT MANAGEMENT PLAN CERTIFICATION
Name of Farm:
Owner/Manager Agreement:
Uwe understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. Vwe know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, wilt require a
new nutrient management plan and a new motion to be submitted to DWQ before the new
animals are stocked.
Uwe understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from.the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner:
Signature: ic C
6—/9— o
Name of Manager (if different from owner):
Please Print
Signature:
Date
Name of Technical Specialist:
Affiliation:
Address:
Signature:
Sonya J. Barber
Harvest Net, Inc.
P.O. Box 32
Council, NC 28434
(910) 6464758
Page: 7

WASTE UTILIZATiQN PLAN
REQUIRED SPECIFICATIONS
I _ Animal waste shall not reach surface waters of the state by runoff drift, manmade conveyances, direct application, or direct
discharge during operation or land application. Any discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the producer either owns or has a notarized agreement for use of
adequate land on which to properly apply the waste. If the producer does not own adequate land to properly dispose of waste,
he/she shall provide a copy of a notarized agreement with a landowner who is within a reasonable proximity, allowing him/her
the use of the land for waste application. It is the responsibility of the owner of the facility to secure an update of the Waste
Utilization Plan when there is a change in the operation, increase in the number of animals, method of utilization, or available
land.
3. Animal waste shall. be applied to meet, but not exceed, the Nitrogen needs for realistic crop yields based on soil type, available
moisture, historical data, climate conditions, and level of management, unless there are regulations. that restrict the rate of
application for other nutrients. Actual yields may be used in lieu of realistic yield tables at the discretion of the planner.
4. Animal waste shall be applied on land eroding less than 5 tons per acre per year. Waste may be applied to land that is eroding
at more than 5 tons but less than 10 tons per acre per year providing grass filter strips are installed where runoff leaves the
fieid. (See FOTG.Standard 393-Filter Strips)
5. Odors can be reduced by injecting the waste or disking after waste application. Waste should not be applied when there is
danger of drift from the irrigation field
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated on conventionally tilled cropland.
When applied to conservation tilled crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff does not occur off -site or to
surface waters and in a method which does not cause drift from the site during application. No ponding should occur in order
to control odor and flies.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the surface is frozen.
9. Animal waste should be applied on actively growing crops in such a manner that the crop is not covered with waste to depth
that would prohibit growth. The potential for salt damage from animal waste should also be considered.
10. Waste nutrients shall not be applied in fail or winter for spring planted crops on soils with a high potential for leaching Waste
nutrient loading rates on these soils should be held to a minimum and a suitable winter cover crop planted to take up released
nutrients. Waste shall not be applied more than 30 days prior to planting of a crop or forages breaking dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following: The outer perimeter of the land arcs
onto which waste is applied from a lagoon that is a component of a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river other than an irrigation ditch or canal Animal waste other than
swine waste from facilities sited on or after October 1, 1995, shall not be applied closer than 25 feet to surface water. This
distance may be reduced for waters that are not perennial provided adequate vegetative filter strips are present (See Standard
393 - Filter Strips).

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
12. Animal waste shall not be applied closer than I00 feet from wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those owned by Iandowner.
14. Waste shall be applied in a manner not to reach other property and public right-of-ways.
1 S. Animal waste shall not be discharged into surface waters, drainageways or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided it has been approved as a land applications site by a
`technical specialist". Animal waste applied on grassed waterways shall be at agronomic rates and in a manner that causes no
runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall not be discharged into the animal
waste management system.
17. A protective cover of appropriate vegetation: will be established on all disturbed areas (lagoon embankments, berms, pipe runs,
etc.). Areas shall be fenced, as necessary, to protect the vegetation. Vegetation such as trees, shrubs, and other woody
species, etc. are limited to areas where considered appropriate. Lagoon areas should be kept mowed and accessible. Lagoon
berms and structures should be inspected regularly for evidence of erosion, leakage, or discharge_
18. If animal production at the facility is terminated, the owner is responsible for obtaining and implementing a "closure plan"
which will eliminate the possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular basis to prevent breakdowns, Ieaks, and
spills. A regular maintenance checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it should only be applied preplant with no further applications of
animal waste during the crop season-
2 1. Highly visible permanent markers shall beinstalled to mark the top and bottom elevations of the temporary storage (pumping
volume) of all waste treatment lagoons. Pumping shall be managed to maimtam the liquid level between the starkers. A
marker will be required to mark the maidmum storage volume for waste storage ponds.
22. Soil tests shall be made every two years, and a liquid waste analysis shall be taken at least twice each year consistent with
waste utilization plan. Poultry litter shall be tested prior to application. Soil and waste analysis records shall be kepi for five
yam.
Dead animals will be disposed of in a manner that meets NC regulations.

Gi-ISTE U7TL.IZATION PAN
R2QUIRED SPECIFICATIONS
1 Animal waste snail not _each su= ace wEters of the szaze hL
i10f Cr_=*z, Zia —load~ C;_n-Jeya'ces, Ci acc! iCct_GP_ Cr -
C'_r��t disc mar a c: ri=?C operation or i C
CL waste wriCn reac' e= cur�-ace water is Cr;f? big
2. There utust cz CCCument,at i on in t=l- Ces_G-n L of det t'_^_=: the
roduce_ E1%='eY Cwns Or` has an acraeme =% =or use Of GC?^.L'GzE
arc cn whi Cn to `.roceri V_ auu t 1J t_^_e wasz . _ ! f the _L'rCGL'Car CCES
i_Ot C4.it cL'ECL'GLE la'c to Drccer lV di Sacse Oi Was- ner�S]n shall
provide a cocv C; an acre e itent with c ! ?i?CCwi er wino is wi t ni r, a
re .Soliahle DT_'C:C_mltV, al lcwi nc the use of the }and I
waste appliC=t icn. It is the TreszoP.Si^t_I i ty of ti1e Ctvmer of t'a
. acili y� to secure an L'I_datothe Waste LtliZaQn piGn when
e= ? L_T
there is a chlance in the CCeration, -increase in the number O'
animals, method of utilizatioP_, or available land.
3. Animal waste Shull be applied to [fleet, but not excee^_, the
nitrogen needs for reM.11et`.i C crop yields based on soil ty_.E,
available moisture, historical data.; Cli-nai`.ic conditions, and
level p= me-nace!lient, unless -there are regulations that rec`ri Ct
the rate of auD 11 cat iol; YCr ot__^_er P_L'i rinilts .
G . Ali Yilal Waste si:all he aunlizC to land erodinc: ? eSS tna, r, toi:s
per acre Der year..Waste may be anolied to lc.nC that is Er'odi_ a
at 5 Cr" more tons, but less than !0- tcr_s per acre per year -
^.roVidi _lc C?'ass filter strips are i nsta i led wi1ercc r'ano= l E"vec
tna ]Ei d - (See =OTC 5tE ca_=4 3O3 -Filter Strip)
S . Odors ca.II he re- uce:'. b ins ect n- c t e waste or Gi c i er
J K_:?C a�
waste a-omlicat?On_ �"lGSL? 5^OL:IG not 1✓E acDliaryl W!??*1 tncre i c
dancer of C,?fft n_Glli the irricatjcn
6. When a_:! mGl waste is to he auclied, On acres subject to
_! ooai C, it- will- he soil- i ncc pCrated- on con- e_ltioi!aliV ti lied
cropland. When applie^_ to conser-vaticn tilled CrODS or
Crass nd, -the waste iiav be broadc-ast 'provided the application
does not occur during a SeS.Son crone to flood-inc.
(ice "WEcC.^_or
and Climate i?1 North C-arolina" for gu cance.) .
�
7 . L_ 5t... be C D__ C ` ac.- a
Quid -wG a shall l i o^. at rates not to e_ see z tiZ
s i
C_�
_
infiltration rate sus?, t aat ?"tiiOLi Cues Plot Occur orEsite
or §b
surLace wat=-s and in a method which does not cause driLL
irCj
` sites rin l ' -t c� .7
tie t Qii__ C ci]D_icat_Cs_. A!o COnd? =e hoL_d occur
_ _
-'
orGc&
1l
to control OCOr Or z! icS .
C
� �
� v
E . _''-?3i dial waste shall i b l e^ s` tr- - -.:
L� _a_ T.GL w..0 Gri �.�- t� a..L._GL �.1 Soils, C.Lti'i^r"�
E.
-__n�a_l e = PLC r
C A—n-ima Wasce S.nali Ce E:_ l_== cn aCZ'-i=! V C_ri.Wt _C cz::cs
_•
_s`'c
Man e_r t: at t �� �a t S �L C�^%ti--� .Y_-^ sNC `L� to a �Gr
L y L ._-
iJCL:iC P_ir_= Cr; w� �'=e LCC=cam_=i r=_ Sa_: Cc`CC_e --aria
cnj_..M_
hcu Id

r73(
►.i
L1t
z
0
�I
N
fa
?-I
a
.1
t)
,-1;>,
rii
U
0t
Ul
i
r !
IU
11
IU JJ
[! In
JJ
11t
'U
UI
E
1)
r
,u
1:: 11 111 U
AJ Ut
0 r: E)
In
1 I
N
r•Y r,
U) ;> O
a}
V)
4-I
Vi
go 0) -1
'U 'Cl al
0
U
'Ct
0 111
ri (: IU
�. IU rl
IU
D
4-I
I
U
r;
� •r3
0
:I 10
i•I
'1
D
I
-•r1 •1-1 ILI
4-I
C'
Ul
11)
EJ
E 11)
Ifl
t]1
[ll 0 rl
(], 1J
,t
11
W
JJ
O
1.1
Vl
', Pt a)
0
JJ
JJ
II -I
JJ
r
w
(? Ill U) It1 •rf
JJ C U} r
) I
111
•C1 ,L}
rl
JJ N
r,
J.7
-J.I
(],
i•I
(1)
IU
1•I
•rl
'iJ to r1
U
Ili
•rl
�
+ •rl
Ul
,i]
.{)
3 () 41)III "
�I
J
1J
C)
U
IIJ
UI
,-I
rl
1
,1
•rl VI
rl
Ill (} al
I:: U `U
;> }r
•rl tll It
rl
U)
{ll
tl)
11
J-)
CJ, r; of
1l
ILI
I
.0
a? 'd
+
U,
- U 0
'1.l•; U 11
C1
I
�],rr
tll
_
iJ •rl
M ,C: Q)
111
4-t
tl1
IE I
tl)
,r:
IU
3
U)
I
tU r�+ Q, 01
rt to JJ
al
•r1
1-1
•rl aJ
Ul
V) IU iU L)
11•E
•r•I
:R
rI
it i
(]
V)
(},
00 U)
01 cis
1-1
10 UI
14-1 a)
JJ ,Q
J-I U O
•r1
r'
JJ
�t
.C)
L71
IU
rl
O
JJ
.Lj C,
tU 1)
'!t
()
IU 1•r
11
{) U) M
0 1J
ri
O
O
O
D li
0
Ql
Ul
U aJ al
3
171
rt tU
rl E
U1 U1 .f'
1.1
lJ
tU
it
0
UJ
rl
0) U
41)
1-1
N tl}
C:
U
:�
It JJ .L?
Lilll•I
r•I ,C::
rl .�?
U) al IU r-I
U
L!
Ul
U
a) 11.1
,L]
11 ; ,
JJ 0
, 11
U
Id
1.1 I
O
U •1-1
U]
C:
0
IU
4.1
U U
rl (i
Cl tll 1 1
t11
III
ILI
n
IIl JJ C:
J.) IU to
III to
a)
r;;1-1
,
JJ
O
�:
IU if)$
to
0) It It? 'Ci Ill
rl
{?
JJ
a}
W U
U
tU
Ql to lI
3 a1
(]1
IU
t:
N 0
C; 'C]
aJ
�}
S
U)
.�1'f]1
(µ+
C:.p
L.
N } '1
IU
(]
',>
0
0
F 1J
JJ IJ
0
JJ
JJ 0
r]
0 Q)
U) U) it L) (I)
tt-}
t:
U
i
U
r: 01
rl U
Ul rt 4.1
1J
l0
0
D
O
N 1J rl
yr{
A
-rI
IU fU IU E 11)
Lil
0
r1 11
if
Ql
�r (',
0 4�
rf
J 1
-W
:> to N
r-I�
N
O
'L)
1U U
- C: 0 ii
•r[
f
•rt
to
U
7J
13
(�I 0
to •rf M
al
IV
V?
al
V) al
JJ
r:
(1)
�)}
0 U .r:
JJ
x
,C; J.)
JJ 0
`t) U JJ 01,0
r4"
Q1
Ql
M
lU
o
4•t
Ul JJ •r1 r, 0
11)
0
0
0
•rt
1.1
(„) •rl V)
U
N
U)
U) 0
(1) Ut
U) '1 a) 111
11J
'Cl
JJ
W
,�' U}
IU
it IU 0)
(" ry
4.1
rl
.C;
rl JJ
r:
'Cl
U r1
4)
1
L}1 il)
U U) `Ct
111
•rt
IU
Ill
�I
r
•rl
U1 .r:
1J
)-1
al rt a1
JJ 4•1
Q)
U
U
N
to
.Li
QI a1
)-I UI JJ
i1
•r)
QJ
JJ
r(
r1
al rl
>
C q) [I
r10
O
'.) tU
0
�I
Lfl
N
`�
,
'[j A
l•I
Q)
I)1
U
0 Ili V)'0
lA
Ili
r-t
It.l 0 •rl .Ll I),
QI
171
JJ I0
I-t_
0 D
arl� r] 'C1
V)
U)
a1
r�
i l
Ili
w
•r1
•r1 N
1-1 10 3
U)
N
3
U
0 Ili
Ql 11i
v1 E u)
i],'rr
rl
1':
al
Ul 0
�
E lfl
1.11 IU W
G, 01
•,-1
•rl 'C'1
P.
0
al
JJ
}•} .0
L14
JJ Ill
W 1J •rl '[1 r:
}11
•,•t rl
'U
to
3 Ul
D
IV 0
V JJ
III 'rl
r-1
rl 111
to
AC,
I}
It1 rt
U)
+
to
in
Ii1 111
•rl it
.0 ill r-I rl •11
LI
ill
(11
0}
Ut
ILI
,Cj
IU
r:
'Li
X. i I JJ
�-' I" U)
r , 10 •rl
U V1
.S ; l i
Dr�i
�1
�
9
U)
to
0 rl IU
1•I
V)
.C;
4}
1.1 to
r1 0) QI U 11)
I
�Q
rl
0
JJ
•rl
a)
111
ri
IU
JJ 1-)
LJ)
01
IU
[J1
0
•rt
'IJ
JJ E
Id
>1
J,
JJ Q)
q,
r1 01 l-t X ,}:j
ILI
rl
t-I-•r
1
• JJ
1.1
,(t a)
M UI
l l
IU
W
},
IU •r1
X:
go
U) U JJ
0 10
Ili Q) IU U?
.f:
1-1
f)
7
Ul t:r
•,•1
O) rl
G 0 Q)
N l•l
a)
4, a,
r
,�
'[7 i'
t
U
t I
IU J.? U)
7 I a1
.0 'L1
U
U
Ul
•L1
U7
JJ Ilt
Ul
U)•rt
{} •rl
U} ltl
'�
r!
w
U)
Q) V) a
•rt IU
in
l
1
al
a)
3 N >,
(j,,W
U) - U] Y
Ill
C
C
G1
C: r-I
Fi rr�f JJ
♦•I ,1 JJ
0 JJ
.Ia 0
U)
,Cj
'U
r[
'C}
JJ
C'
CI
Cn
r»t -
O, }3
0
tlt �)
Ul
I
'U
rt
0
w
•,•l
to
II1 t�1
I
r�,•r-1
JJ
M1 IU
3 OI
Ii•I U •r1
rl r^I
JJ
J.1 ,C,
'Ll >1
JJ
r,
c} O
It$
N
IU N JJ
Ili
1J
U al U
IIl J.l 11
rl
I 1
'L7
1.1 0
•rl
0 1V W
JJ rl
'U •rt •rl
U •rl
I+I
0
0 J,
a1 tU
0
W
R1 w >:
JJ
E
•rl y C"i
11-t U)
.t.
0) C it) to V)
w
IU
U)
L)
r:
1J JJ
wl
rt .1.1
r; 'U U
'l:i
r;
•rl $
rl I
r:
rl
1.1
rU J .tJ
0 Ln
to
ILL
t~I >r a}
O rt
I I U
U
C.
U.
�
1U
"}
•.-1
r-1 in
IU HS
a) I
r-1
rt ILI
0111.1
rl
a)
a) )•r •rt
,L:
JJ
N
to
JJ -1 E
U) Cll lu
'�)
i
r1; •rt - 1•' UI
Ul
{)
i 1
r;
E
L:: M
U
0 •*I rt
C: 11-I
'!,
•r1
rl
rl Ci
01 0
L},rl
U)
C;
rj Ul
l
Ill rl
JJ U! U ,I)
111 II) U it
II)
111
III
U
a)
..i
0
ILI •,•1
Ili
4•I
4.1 rl
0) Ill
0
�I •rl
r-I r.)
(],0l
to
l0 1J
lU 1
lu
Pi to
V•�)
VI
•rl
'rj + 10
5 -1
1., •r1 01 .`.)
Ill
JJ
E
i I
a) 1J ,f:
ill JJ (}
Oil)
.r,
W
rCl
If) I•l
JJ
(}
,C.,
V)
�I
0
r>1 IU rf
U
rr1
,U
1-1
r V) i-t
0 Ili
.- Q) Ll to 1.)
C;
'L1
Ul
U)
rl
U)
Ut L},
al
L; U) ul
'
Ili
0)
rl:11
Ul
tU
E ]:, a)
Ili
'i
Ul
V)
a)
•rf 1J lu
a) E
U
LI, a) 1-1 U
III
o)
I
I])
JJ
to
;Z
r:
-r•I
its
Ul Ul
1':
1
iJ IU
$
Z U)II I
'C3
111
of .C:
10
•rl
al
+
U1 171
I
J�
'U
I::
0
L} n) tJ, }
J•1 a V1 1
tl1
r1
•rl
0 k Q}
a) 1 i
JJ
U)
JJ JJ
rt M
JJ
V)
(1) 41 U)
(1)
i•I
(U
r: •,-I a)
J.1
fll
It1 1U
U1
1.1 ,f; IU
1.1 JJ
.0 to
'U
IU
U) 0
rt .
N
,?,
JJ A
JJ
0)
),1
,U 0 JJ
•r��l
I.]
r-i
IU
1•I 'C}
•rl U 44
,Lj
•rl U)
.1J r:j
EU
;3 IA
IU' U
'rf
IU
3
iU
�
Vl r-f
QI W
1U
3
'C',
J-1 U)
J.1 Ill
+,C: 'L) 1.1
(';
1::
(It
L71
I:
C)
ti,
7
3 •r)
:>•r Ili
0 t
UI
.M
W rl
Q)
IU
; :> U
JJ
O
U
-r! Al
U to
•rl $
L} .r::
111 U}
V) JJ U ill ILI
G:
(.}
I
tll
k}1
r f
!J
!), O U
U I.1 C:
QI
[ i
,C: al
;>1 C:
EJ r; �
1:: JJ
rl
r! r;
L
�D
r- I
U)
Ili •r-I
'C1
JJ
JJ 11)
JJ •r!
U •r, I:
-J it 't 11 to
•.
V)
JJ
I::
,C1
rU
rr •rf
I. IU
a1 4)
U)
r!
ICI
rz U)
to •rf
[7
0}
10
to
rf 4 r�
a1
C:
U •rl
V) �l r1
0 rl
�1 t•) U,
(!
Ul
•r•I
bl
U 'C)
n) r:
ti,
U1 0 ;�
Lar ;, r,
r-1 a?
•rl rt
rl
•rl rl
JJ RI
v)
(.'.
r I
r::
•rl
IU .C:r
(- :11 L)
U)
U!
()
L.: U)
0
a) a) to
r::
1•t ,rj
41? I l 0 V)
11
`I[I
tl1 r I
.!,? l0 11
%'
r.,;
lY JJ tQ
fj Ili •rl
lU 11)
r' ,-(
r:' a)Ili
't
'ci
111
•r-I a) n}
Ili
'L:
1 I a1
1ti
0 U •' �
G1, to
EJ
w JJ a) 11 (?
O, 0 .! ; 1, 3,
IL)
U1
,-I .t.,
JJ JJ 'U
U U to
CJ1 JJ U)
U1 `-^
rt; IIl
r•I;
,{ 1:,
rt,
1,
I .I:, JJ
it
1':
rl; V)
•.-I 1t tJ !), Ill
II-1
3
'U
ILI
'U
rl, JJ r
Ut
!U
(U J.)
U) IU
N
114 11, U Ili Ill
U
D
e-!
* 1
f�l
rl
t1'
1
if'
>�
t-
rt
,-1

WASTE UTILIZATION DL. AV
. 3EQi"i FIRED SPECIFICATIONS
IT animal Croducz__n at �__^_a _=C_11t�/ i S to be c;lc;..cr._4r; Cr
the aur_e-- is reszonsinle IEcr obt- _ G-d
__i� lnrncntsnC a.^cics'ura lJl=nn Wt_=Ch ,,/ill
pCcS;'r�i i i tV of an i 1 i coal C_SC8?a;Ge, PC! i 13ti CTl a�C =,":Si
-s TNasze handling structure.-5, L1_pil"G, FURICS, reels,
on G T_cptllr r... GC1C to j]YevC'_7t _[c
� 1
S i 7 1 a re_Ljlar i� a nt--=n.a�Ca the k i c4 S.Iou1C be . k cC Cn
G._C S. -- _
20. \n 7 mal waste Can be used in a rotation that ins uEes
and of -er Crops for d -rect J?E mETTl consumption. HGWev=r, � { f - -
animal Waste is Used. on Crops for C-Teat human con5i_iuot-CiZ i t
5"IculQ only be aaplie.; *,rep1slat. With- no 'further appi CaticnS C_
animal Waste d rInG the Crou sensor-.
2 1 i chly visible markers shall be installedinst-alled to iilark the tOD a:!C
Cattcm elevaticns of the temporar-y storage (pumnpi nc: voluzileJ G`
all Waste treatment l aC_Cons . . Pumping shall be managed tc
i0ai n _.c_a the -li Gni d level between the markars . A marker w- 1 i
ce required to mark the talcximum Storau_e volume -for Waste
StoraC^e- ponds.
LZ . Waste Shall be tested Wi thi-n Ep days of utilization and SO? 1
shall be teste^ at least annualiv at- Cron sites Whe-e Waste
_-oducC -s are applied. Nit -Caen an -all be the rate
41 c'.11ent Zinc and Copper levels -in the sOi 1 s shall he - --_
monitored and alter ate-v'c Crop sites shall be usewhen th,
Metals approach excessive levels. . W shall be adjusted for
ODC i ii UM Croy nTOCUCtion and ma" nta zleC - SOiI and WcSta
anti ys i ss records S' all be JkeDt. for ; ive y e= rs . d
Waste aculicat?on recores shall be ma3nta noC for t^- {
ti%e?rs. waste aJD1iGaticp_ records for all other Waste`s}-all ya
tila-int=ined for five (5) years.
73. Dead e.Tl? mall Wi 1 1 be Ci SOoseC of Tn a manner that meets �'ICrt-
cEroii na reaulat i ons .
I have dead and under Land this document.
Si gnature:
Date : //-- j -p

WASTE UTILIZATION PLAN
r r----------------------
owners name --:Barnes Farms, Inc. County:Columbus
Mail Address-:206 Cambridge Blvd. Lumberton, NC 28358
Type of production unit---- :FEED -FIN
Number of animal units-----: 3520
Type of waste facility -----:Anaerobic Lagoon
Temporary storage period---: ]BO days
Method of application ------ :IRRIGATION
Amount of animal waste produced-----------------: 6668 tons/year
Amount of'plant available N produced by animals-: 8096 lbs./year
Commercial N to apply on planned acreage--------: 0 lbs./year
Your animal waste utilization plan has been specifically
developed for your swine operation. The plan is based on the
soil types, crops to be grown, and method of application for
your particular operation. The waste must be land applied at a
specified rate to prevent pollution of surface and/or ground
water. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops
where the waste is to be applied. This waste utilization plan
uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle and annual soil tests
are encouraged so that all plant nutrients can be balanced for
realistic yields of the crop to be grown.
Several factors are important in implementing your waste
utilization plan in order to maximize the fertilizer value of
the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the
needs of the crop to be grown and the nutrient content of the
waste. Do not apply more nitrogen than the crop can utilize.
Soil types are important as they have different infiltration
rates and leaching potential. Waste shall not be applied to
land eroding at greater than 5 tons per acre per year. Do not
apply waste on saturated soils or on land when the surface is
frozen. Either of these conditions may result in runoff to
surface waters. Wind conditions should also be considered to
avoid drift and downwind odor problems. To maximize the value
of nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing Crop or
not more than 30 days prior to planting. Soil incorporation
of waste will conserve nutrients and reduce odor problems.

t • D
Page 2
The acres needed to apply the animal waste is based on typical
nutrient content for this t e of facility. Annual acreage
requirements may be more oreas based on the waste analysis
report for your waste management facility.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract
Field
Soil
Crop
Yield Lbs. N
Acres
Lbs. N
Month to
Acres to
No.
No.
Type
Code
/Acre
/Unit
Used
Apply
Overseed
1
1687
1
St
C
5.5
50.00
4.3
1182.5
MAR-OCT
1687
1
St
L
0
133.00
571.9
S-APRIL
1687
1
Fo
C
__1.
50.00
3.0
900
MAR-OCT
1687
1
Fo
L
0
133.00
399
S-APRIL
3.(
1687
1
NoA
C
6.1
50.00
5.7
1738.5
MAR-OCT
1687
1
NoA
L
0
133.00
758.1
S-APRIL
5.1
1687
3
BuB
C
5.5
50.00
3.9
1072.5
MAR-OCT
1687
3
BuB
L
0
133.00
516.7
S-APRIL
0.(
1687
4
NoB
C
6.1
50.00
4.0
1220
MAR-OCT
1687
4
NOB
L
0
133.00
532
S-APRIL
4.(
Available Nitrogen
Total 20.9
(includes commercial)
Surplus Or Deficit
Crop codes: Crop -unit
A=Barley-bu.
B=Bermudagrass(graze)-tons
C=Bermudagrass(hay)-tons
D=Corn ( grain) -bu .
E=Corn (silage) -tons
F=Cotton-lbs. lint
G=Fescue(graze)-tons
H=Fescue (hay) -tons
8893 17.{
8096
-797
I=Oats-bu.
J=Rye-bu.
K=Small grain(graze)-acre
L=Small grain(hay)-acre
M-Sorghum(grain)-cwt.
W=Wheat --bu .
Y=Fescue (pasture) -tons
Z=Bermudagrass(pasture)-tons

Page 3
If more commercial fertilizer is used than shown in this flan,
then additional acres of land may be needed. A three to fifteen
feet wide permanent grass filter strip should be seeded along all
ditches in fields that receive animal waste.
Additional comments:
--------------------
Prepared by: �7�.. Lt�.� Title: .S C Date: Z_ 3 -9 r
Concurred in by: _ 'e- Date: .9-3 9 S'
Producer
I understand that I must own or have access to equipment,
.� primarily irrigation equipment, to land apply the animal waste
described in this waste utilization plan. This equipment must be
available at the appropriate pumping time such that no discharge
occurs from the lagoon in a 25-year 1-day storm event. I also
certify that the waste will be applied on the land according to
this plan at the appropriate times and at rates that no runoff
occurs.
&tA Date.
Producer
Technical Specialist: Date: 4'.3-9,C
(Copy to producer and copy to case file)

WASTE UTILIZATION PLAN AGREEMENT
b ma of Fans+
Ow¢ulMaoaga Agremeat
t W m WWstand and wilt follow aW imph m M the speeiflafin s m the aparatian and maim tame
Finah es established to tin appnov waste utmmrm plan for *e farm p store. I (we) know brat any
ono to the a ds ft hdp aapadty of do waste fr o l 1 1 and storage facilities wM require a new
cadfidador to be odmdtted to the Ob"m of Env' raaaraa#al Unagement (0EM) before tw new anhmb are
sleeted. I [roes also b9dwomusthemodinharpdwasboutrreots from this system to surhm
maim of the state from a atom ernmrt kris swm+e dm the ffir, 24hr storm. lie apponad pkaa tail! he fbd
mdibe at the farm afftee and at ttm lace! Sad sad Water Coumveft Distrfet afflee and wilt he mflable for
I bw mi A 1 , - t i that I {wet most arm or have acorn to hrigatioa or ether ait 4orent for the land appilaatim
of the animal wasbn this waste atilintim p1am. This quipmM must be available at the
apI m I ': It pig tiore surd, that no duarge acems from do lag= in a 261r. 24hr storm er=L I (we]
also certify that the waste wdi be applied as the land sc ar ft to this plan at the appropriate than amd rates
sm6 that as rucal accam
,lame of Lmd Owner (Please PrhrtY.
5
Sam of Manager Of Oferert from owno*
Datm - /_ J o l
Sim -Mtn A Daft
IYarae of Technical S (P Printk h AAI"�& t?_ Aec1 s1or
MCCES.1Nt1P varsion t. mue t t

, � fir, � � • •w� ,j
�"
bond

WASTE UTILIZA.'TION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land
application. Any discharge of waste which reaches surface water is prohibited.
Illegal discharges are subject to the assessment of civil penalities of $10,000 per day
by the Division of Environmental Management for every day the discharge continues.
2. The Field Office must have documentation in the design folder that the producer
either owns or has long term access to adequate land on which to properly apply the
waste. If the producer does not own adequate land to properly dispose of waste, he
shall provide NRCS with a copy of a written agreement (sample enclosed) with a
landowner who is within a reasonable proximity, allowing him/her the use of the land
for waste application for the life expectancy of the production facility. It is the
responsibility of the owner of the facility to secure an update of the Waste Utilization
Plan when there is a change in the operation, increase in the number of animals,
method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for
realistic crop yields based on soil type, available moisture, historical data, climate
conditions, and level of, management, unless there are regulations, that restrict the
rate of application for other nutrients.
4. Animal waste may be applied to Iand that has a Resource Management System
(RMS) or an Alternative Conservation System (ACS). If an ACS is used the soil loss
shall be no greater than 10 tons per acre per year and appropriate filter strips will
be used where runoff leaves the field. These filter strips will be in addition to
"Buffers" requried by DEM. [See FOTG Standard 393 -- Filter Strips and Standard
390 (Interim) -- Riparian Forest Buffers.)
5. Odors can be reduced by injecting the waste or disking after waste application.
Waste should not be applied when the wind is blowing.
b. When animal waste is to be applied on acres subject to flooding, it will be soil
incorporated on conventionally tilled cropland. When applied to conservaton tilled
crops or grassland, the waste may be broadcast provided the application does not
occur during a season prone to flooding. (see "Weather and Climate in North
Carolina" in the Technical Reference -- Environment file for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
runoff does not occur offsite or to surface waters and in a method which does not
cause drift from the site during application. No ponding should occur in order to
control conditions conducive to odor or flies and provide uniformity of application.

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when
the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that no
more than 20 to 25 percent of the leaf area is covered by solids.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste nutrient loading rates on these soils should
be held to a minimum and a suitable winter cover crop planted to take up released
nutrients. Waste shall not be applied more than 30 days prior to planting of the crop
on bare soil.
11. Animal waste shall not be applied closer than 25 feet to surface water. This distance
may be reduced for waters that are not perennial provided adequate vegetative filter
strips are present. (See Standard 393 -- Filter Strips)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and public right-of-
ways.
15. Animal waste shall not be discharged into surface waters, drainageways or wetlands,
by a discharge or by over -spraying. Animal waste may be applied to prior converted
wetlands provided they have been approved as a land application site by a "technical
specialist". Animal waste should not be applied on grassed waterways that discharge
directly into water courses, and only then at agronomic rates provided the application
causes no runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc.,
shall not be discharged into the animal waste management system.
17. Lagoons and other uncovered waste containment structures must maintain a
maximum operating level to provide adequate storage for a 25-year, 24-hour storm
event in addition to the one (1) foot mandatory freeboard.

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
18. A protective cover of appropriate vegetation will be establised on all disturbed areas
Magoon embankments, berms, pipe runs, etc.). If needed, special vegetation shall be
provided for these areas and shall be fenced, as necessary, to protect the vegetation.
Vegetation such as trees, shrubs, and other wooded species, etc. are limited to areas
where considered appropriate. Lagoon areas should be kept mowed and accessible.
Lagoon berms and structures should be inspected regularly for evidence of erosion,
leakage, or discharge.
19. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
20. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks, and spills. A regular maintenance checklist
should be kept on site.

U. S. Department of Agriculture
Soil Conservation Service
HAZARD CLASSIFICATION DATA SHEET FOR DAMS
NC-ENG-34
September 198O
File Code: 210
-- ... _ ! •- Fug Z*Cj Countys--
Community or Group No. Conservation Plan No.
' Zysad
of Dam_.j�s" Ft. Length of Flood Pool ',Is'a Ft.
Date of Field Hazard Investigation -TJ-� .
tvdluaLlUlt uy •=$A,... ,,, ._- .am to the point of estimated minor effect
from sudden dam failure.
Est. Elev. ST.__L1eY2`."
Kind of :Improvements: of Breach
-gth: Width:
Slope:
Land Use
Improvements : Above :Floodwater L--===
Flood Plain: ' Flnnd Plain
Ft.' Ft.
Y -
Ft.
SD . -0 a
2 : : �� :
:
•
• 4sa
0A •
11aL
•
•
- . iJooDs�
: •
3 :3'1B 3'A:
old us �+
i - : /.S �tal :
. ie
1 t % f`
: :
"-- 4-_ ential for loss of life and damage to existing or pu,_- ==-
improvements from a sudden breach
Hazard Classification of Dam 6] b, c) (see ITEM -Part 520.21)
' Classification (I, 11, I1I, IY V)
name) (title
Concurred By o`, (a� - &Q,,
name) u (title) . . .
-. NOTE: I. Instructions on reverse side.
=-N-nal sheets as needed.
Date Z—/o — s—
Date

Rew S-7tl .
tL S. DEPARTMENT Of AGRICULTURE
SOIL CONSERVATION BEMCE
^t'^,►T'„N TO DETERMINE SUITABILITY OF PROPOSED POND SITE
FARMER'S NAME ,ice CIl� r�+ 1lL�� DISTRICT
A q' -- COUNTY --
S. G. S. PHOTO SIIEET NO. • WORK UNIT
f inn �n5-;ti7 AREA MEASUILLMtNT3
_ =-=SWRE_.^.. ACRES
WOODL.AND_,—ACRES TOTAL---.,— ACRES FOND CLASS WORK UNIT CoNq TIVATTOLOST
■aaaaaaaaaaaaaa■
aaaaaaaaeraaaaaaa
as�E�M
-�.���MM■
EN No
ar�aa���aaar
a■
HTEM
OR
131E
■amiaa
a aaaaaaamaaaaa■
■aaEMMEmmum
■EMMEMEosomm
amreW
m
M
moomm
Em.
_
10
w
■aaaaaaaa
.,
■EMlM�NMMM
OEEEMMaaaOM■
OMEN
�rMMaEEMaEEaNaaaMaa
MENNE■
rommossommom
:i
u �.
'44, sew« or"o"d bormw off own ". mroomR �,�.......,�. .
TCanMnwd ew bacR rVlrrw we[naeryT sAsa —= __"- lle.tnrf.
r►AT C
10 as
n �l m - Is5 ���5_Cr1� �•`3'n 5� S ftl =_ -
l 3 -a i q •u - _ _� _ _ _
• i -�,+ -f; - -4r [A1- - - --5� Cr? - of �� �-- • �n ��
_ :--��
er—lo Fig
=;ARE & Trnz
Aw

z TYPES OF MATERIAL ENCOUNTERED IN BORINGS
(Use one of systems below) '
UNIFIED CLASSIFICATION . USDA CLASSIFICATION
Well graded gravels: gravel, send mix - . g-gravel
-Poorly graded gravels s-send
GM -Silty gravels; gravel -sand -silt mix vfs-very fine sand
- _layey gravels; gravel -sand -clay mix sl • sandy loam
SW -Well graded sands; sand -grovel mix fal-fine sandy loam ..
P-Poorly graded sands. el -loam
SM- Silty sand &I -gravelly loam
sand -clay mixtures-
ML-Silts; silty, v. fine stands; sandy otclayey silt all -silt loam
CL-Clays of low to medium Plasticity el -clay loam
Cll-Inorganic clays of high plasticity sicle silty clay loam
MH-Elestic slits scl-sandy clay loam ,
OL-Organic slits and silty clays, low plasticity sic -silty clay
-- _--=-r -'-- n:ediusn to bigh plasticity c-clay
I. Suitable material for embankment is available ©•Ye■ 0 No (IMUM14 �►►�-_ ' _' ' -- '` '!'�� �'
wwrsr ddet _
REMARKS:
`Mct�•� /.�,....' !�-r'�-�--.•..�.. df/� ,ltJ.`J`''�' � IQt`j ``"- ..4+-", -��i6" =
0117,
4 Explainhazards requiring special attention it, derign Rffavay.imW;orA .
GENERAL REMARKS:
0131319393113
- - oI
Aff

UNITED STATES SOIL
DEPARTMENT OF CONSERVATION
AGRICULTURE SERVICE
------------------------------------------------------------
WASTE MANAGEMENT FACILITY SITE EVALUATION
GENERAL INFORMATION L/e if. of efou
NAME-----'c`.'=?� — ----- -d--� LOCATION T p -M-- -
_
SIZE OPERATION���o'�P�'-G
LOCATION DATA iSv& I-
- DisTANCE FROM NEAREST RESIDENCE NOT OWNED BY PRODUCER------
IS SITE WITHIN 100 YEAR FLOOD PLAIN? YES------ NO-J--
II yes, SCS cannot provide assistance.
IS SITE AT LEAST 100 FT FROM A "BLUE LINE"
PERENNIAL STREAM? YES--Y-- NO ----
If no, site must be relocated
IS SITE WITHIN 1 MILE ZONING JURISDICTION
OF A MUNICIPALITY? YES----- NO -
if yes, landowner should consult with local zoning board
about required perMits. Permits must be obtained prior to
design approval.
(Copies of maps or other reference materials may be
attached to site evaluation.)
WETLANDS
WILL SITE INVOLVE CLEARING WOODLAND OR ANY
NON -CROPLAND? YES----- NO- Y
If yes, producer must complete a Form AD-1026,
DOES NON WETLAND NEED TO BE MEASURED BY REGISTERED
SUYRVEYOR PRIOR TO APPROVING WASTE
UTILIZATION PLAN? YES----- NO.
WILL ACTION -RESULT IN SWAMPBUSTING? YES---- No -&- -
IF WETLANDS ARE INVOLVED, IT IS THE RESPONSIBILITY"OF THE
PRODUCER TO CONTACT THE US ARMY CORP OF ENGINEERS, -AND THE
DIVISION OF ENVIRONMENTAL MANAGEMENT TO DETERMINE IF
ADDITIONAL PERMITS ARE REQUIRED. NO WETLANDS SHOULD BE
ALTERED UNTIL PRODUCER RECEIVES WRITTEN APPROVAL FROM SCS,
US ARMY CORP OF ENGINEERS AND NC DIVISION OF ENVIRONMENTAL
MANAGEMENT.
(A copy of AD-1026 and CPA-026 should be attached to
site evaluation.)

OTHER ENVIRONMENTAL FACTORS
ARE ENDANGERED AND/OR THREATENED SPECIES
PRESENT? YES---- NO-
IS A DESIGNATED NATURAL SCENIC AREA INCLUDED IN THE
PLANNING AREA OR WILL PLANNED ACTIONS IMPACT ON AN
ADJACENT NATURAL SCENIC AREA? YES---- NO -
IS AN ARCHAEOLOGICAL OR HISTORICAL SITE LOCATED IN THE
PLANNED AREA? YES----- NO----
ARE THERE PRIME, UNIQUE, OR LOCALLY IMPORTANT'ARMLANDS
IN THE OPERATING UNIT? YES---- NO ----
WILL THE ACTION RESULT IN SODBUSTING? YES---- NOS ----
If yes to any of these questions, complete forth NC-CPA-16
and attach to site evaluation.
VOAF-
A -e�
ODOR CONTROL
HAS ODOR CONTROL BEEN DISCUSSED WITH PRODUCER...........
........PREDOMINANT WIND DIRECTION? YES-k - NO ----
........POSSIBLE EXPANSION OF TREATMENT
VOLUME FROM I CU.FT. UPWARDS TO
3 CU. FT./LB. OF ANIMAL? YES---- NO- —
........PRECHARGING LAGOON WITH FRESH
WATER TO AT LEAST 112 OF THE
CAPACITY? YES-:f - NO ----
........USING GOOD SOUND JUDGMENT IN
LAND APPLICATION OF WASTE? YES- NO----
WASTEMANAGEMENT
DOES PRODUCER OWN ENOUGH LAND TO PROPERLY
LAND
APPLY WASTE?
YES--Y NO ----
IF NO, DOES PRODUCER HAVE ACCESS TO
MORE LAND?
YES---- NO ----
IF LAND IS NOT OWNED BY PRODUCER,
CAN PRODUCER GET AGREEMENT ON LAND
ON WHICH TO APPLY WASTE?
YES---- NO ----
(Attach soil investigation sheet to
site evaluation.)
SOIL INVESTIGATION --- VALID
ATTACHED
IS SOIL SUITABLE FOR LAGOON?
IS A CLAY LINER REQUIRED?
IF YES, IS CLAY AVAILABLE
ONLY SOIL INVESTIGATION SHEET
ONSITE7
IS A CORE TRENCH REQUIRED?
(Attach soil investigation sheet to
Y ES-- ✓ - NO-------
Y ES-- 2::�- - NO -------
YES-- 'f-- NO------
QUESTIONABLE--------
Y ES ------- NO--
site evaluation.)

SITE APPROVED YES- ✓ - NO------- CONDITIONAL--- ----
COMMENTS- es-�`--'�"-"-�d==------___-___-_._____
THIS SITE INVESTIGATION IS VALID AS LONG AS THE DESIGN AND
CONSTRUCTION OF LAGOON CONTINUES IN REASONABLE TIME
PERIOD. UNDUE DELAYS OR HESITANCY IN CONSTRUCTION MAY
REQUIRE THAT SITE EVALUATION BE INVALIDATED.
SIGNATURE- =u-------- DATE-3L 3r - -

_,--------
i
Operator:RICKY BARNES #2 County: COLUMBUS Date:
01/13/95
Distance to nearest residence (other than -owner): 1500.0
feet
1. AVERAGE LIVE WEIGHT (ALW)
0 sows (farrow to finish)
x 1417 lbs. -
0
lbs
0 sows (farrow to feeder)
x 522 lbs. -
0
lbs
.3520 head (finishing only)
x 135 lbs. --
475200
lbs.
0 sows (farrow to wean)
x 433 lbs. -
0
lbs
0 head (wean to feeder)
x 30 lbs. -
0
lbs
Describe other
0
Total
Average Live Weig =
475200
lbs
2. MINIMUM REQUIRED TREATMENT VOLUME
OF LAGOON
Volume = 475200 lbs. AM x
Treatment Volume(CF)/lb.
ALW
Treatment:Volume(CF)/lb: ALW
= 1 CF/lb. ALW
Volume = 475200 cubic feet
3. STORAGE VOLUME TOR SLUDGE ACCUMULATION rA&r XAC -00ED Baer QW N ex5 RjrQur%r
Volume = 0.0 cubic feet
4. TOTAL DESIGNED VOLUME
Inside top length (feet)---------------------
275.0 (AVeAVAG)
Inside top width (feet)----------------------
305.0
Top of dike elevation (feet)-----------------
51.5
Bottom of lagoon elevation (feet) -------------
39.5
Freeboard(feet)------------------------------
1.0
Side slopes (inside lagoon)------------------
3.0 : 1
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH
WIDTH DEPTH
3.0 3.0 3.0 3.0 269.0
299.0 11.0
AREA OF TOP
LENGTH * WIDTH
269.0 299.0
AREA OF BOTTOM
LENGTH * WIDTH =
203.0 233.0
80431 (AREA OF TOP)
47299 (AREA OF BOTTOM)
AREA OF MIDSECTION
LENGTH * WIDTH * 4
236.0 266.0 251104 (AREA OF MIDSECTION * 4)
CU. FT. _ XAREA TOP + (4*AREA MIDSECTION) + AREA BOTTOMU * DEPTH/
80431.0 251104.0 47299.0 1
Total Designed Volume Available = 694529 CU. FT

5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width
275.0 305.0 83875.0 square feet
Buildings (roof and lot water)
0.0 square feet Describe this area.
TOTAL DA 83875.0 square feet
Design temporary storage period to be 180 days.
5A. Volume of waste produced
Feces & urine production in gal./day per 135 lb..ALW 1.37
Volume = 475200 lbs. ALW/135 lbs. ALW * 1.37 gal/day 180 days
Volume = 868032 gals. or 116047.1 cubic feet
i. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculai
the lagoon water are accounted for in 5A.
Volume = 0.0 gallons/day * 180 days storage/7.48 gallon:
Volume = 0.0 cubic feet per CF
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amoun-
180 days excess rainfall - 7.0 inches
Volume = 7.0 in * DA / 12 inches per foot
Volume = 48927.1 cubic feet

SD. Volume of 25 year - 24
4
1
Volume = 7.0
Volume = 148927.1
l
hour storm
inches / 12 inches per foot * DA
cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A.
116047
cubic
feet -
5B.
0
cubic
feet
�C.
48927
cubic
feet
5D.
48927
cubic
feet
TOTAL 213901 cubic feet
6. SUMMARY
Temporary storage period== __-_________= => 180 days
Rainfall in excess of evaporation ­­­­__> 7.0 inches
25 year - 24 hour rainfall--- - -----__----> 7.0 inches
Freeboard=_=N_ _> 1.0 feet
Side slopes=-- > 3.0 : 1
Inside top length=--------- - => 275.0 feet
Inside top width=== =_- -- 305.0 feet
Top of dike elevation=51.5 feet
Bottom of lagoon elevation===-=_-=---=____> 39.5 feet
Total required volume----- --__ - --=_=> 689101 cu. ft;
Actual design volume > 694529 cu. ft.
Seasonal high watertable elevation (SHWT)==> 45.7 feet
Stop pumping elev.--==--_-_=__===-_----_-_> 47.6 feet
Must'be!> or = to the SHWT elev.---­> - 45.7 feet
Must be.> or = to min. req. treatment el.=> 45.5 feet
Required minimum treatment volume-- -- => 475200 cu. ft.
Volume at'stop pumping elevation===- =_____> 475317 cu. ft.
Start pumping elev.===-------_----_-====_--=_> 49.84feet
'Must be at bottom of freeboard & 25 yr. rainfall
Actual volume less 25 yr.- 24 hr. rainfall=> 645602 cu. ft.
Volume at start pumping elevation== ______­ > 642183 cu. ft.
Required volume to be pumped=====_________=> 164974 cu. ft.
Actual. volume planned to be pumped— --_=__=—> 166866 cu. ft.
Min. thickness of soil liner when required= > 1.8 feet
7. DESIGNED BY.-4j-vQo,,Q APPROVED BY; LD! J207,,
DATE: II141?5 DATE: 3 ,4- %5'
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
COMMENTS: * xee c,/,4,-,o(r i
f3

SHEET 1 OF 2
SPECIFICATIONS FOR CONSTRUCTION OF WASTE TREATMENT LAGOONS
----------------------------------------------------------
FOUNDATION PREPARATION:
-----------------------
The foundation area of the lagoon embankment and building pad shall be
cleared of trees, logs, stumps, roots, brush, boulders,sod and rubbish.
Satisfactory disposition will be made of all debris. The topsoil from
the lagoon and pad area should be stripped and stockpiled for use on
the dike and pad areas. After stripping, the foundation area of the.
lagoon embankment and building pad shall be thoroughly loosened prior
to placing the first lift of fill material to get a good bond.
EXCAVATION AND EARTHFILL PLACEMENT:
The completed !excavation and earthf ill shall conform to the lines,
grades, and elevations shown. on the plans. Earthf ill material shall
be free of material such as 'sod, roots, frozen soil, stones over
6 inches in diameter, and other objectionable material. To the extent
thare suitable, excavated materials can be used as fill. The fill
shaleyy l be brought up in approximately horizontal layers not to exceed 9
inches in thickness when loose and prior to compaction. Each layer
will be compacted by complete coverage with the hauling and spreading
equipment or standard tamping roller or other equivalent method.
Compaction. will be considered adequate when fill material is -observed
to'consolidate to the point that settlement is not readily detectible.
NOTE THE SPECIAL REQUIREMENTS FOR PLACEMENT OF LINERS IN THE LINER
SECTION OF THIS SPECIFICATION. The embankment of the lagoon shall be
installed using the more impervious materials from the required
excavations. Construction of fill heights shall include 5 percent for
settlement. Dikes over 15 feet in height and with an impoundment
capacity of 10 acre-feet or more fall under the jurisdiction of the NC
Dam Safety Law. The height is defined as the difference in elevation
from the constructed height to the downstream toe of the dike.
Precautions shall be taken during construction to prevent excessive
erosion and sedimentation.
LINER: THE MINIMUM REQUIRED THICKNESS SHALL BE 1.8 ft.
-----------------------------------------------------------
NOTE: LINERS (PARTIAL OR FULL) ARE REQUIRED WHEN THE ATTACHED SOILS
INVESTIGATION REPORT SO INDICATES OR WHEN UNSUITABLE MATERIAL IS
ENCOUNTERED DURING CONSTRUCTION. A TYPICAL CROSS SECTION OF THE LINER
IS INCLUDED IN THE DESIGN WHEN LINERS ARE REQUIRED BY THE SOILS REPORT.
When areas of unsuitable material are encountered, they will be over -
excavated below finish grade to the specified depth as measured
perpendicular to the finish grade. The foundation shall be backfilled
as specified to'>i�ade Witfi a SCS approved material (ie - CL, SC, CH) .
REFER .TO"THE SOII;5'INVESTIGATION INFORMATION IN THE PLANS FOR SPECIAL
CONSIDERATIONS. � -

Soil liner material shall come from an a SHEET 2 OF 2
rrow area. The
minimum water!content of the liner materialoshallobe optimum moisture
content which%relates to that moisture content when the soil is kneaded
in the hand it will form a ball which does not readily separate. Water
shall be added to borrow as necessary to insure proper moisture content
during placement of the liner. The moisture content of the liner
material shall not be less than optimum water content during placement.
The maximum water content relates to the soil material being too wet
for efficient!use of hauling equipment and roper compaction, proper
compaction of!the liner includes placement pin g
compacted to at least 90 percent of the maximum inch lifts and
Weight of the liner material. When smooth or m AST74D698 Dry
Unit
shall be scarified and moistened as needed before placemthe ent lift
lift.
The single most important factor affecting the overall compacted perme-
ability of a clay liner, other than the type of clay used for the
liner, is the efficient construction processing of the compacted liner.
The sequence of equipment use and the routing of equipment in an estab-
lished {pattern helps assure uniformity in the whole placement and
compaction process. For most clay soils a tamping or sheepsfoot
roller is theipreferable type of compaction equipment.
The soil liner shall be protected from the discharge of waste outlet
Pipes. This San be done by using some type of energy di ssipator(rocks)
or using .flexible outlets on waste pipes.
Alternatives to soil When thliners are synthetic liners and bentonite sealant.
ese are sppecified, additional construction specifications are
included with this Construction Specification.
CUTOFF TRENCH:
A cutoff -trench shall be constructed under the embankment area when
shown on a typical cross section in the plans. cutoff trench shall be dThe final depth of the
determined by observation of the foundation
materials.
VEGETATION:
All exposed embankment and other bare constructed
areas shall be seeded
to the planned type of vegetation as soon as possible after construc-
tion according to the seeding specifications. Topsoil should be placed
on areas of the dike and pad to be seeded. Temporary seeding or mulch
shall be used if the recommended permanent vegetation is out of season
dates for seeding. Permanent vegetation should be established as soon
as possible during the next period of approved seeding dates.
REMOVAL OF EXISTING TILE DRAINS
_
When tile drains are encountered, the tile will be removed to a minimum
Of 10 feet beyond the outside toe of slope of the dike. The tile
trench shall be backfilled and compacted with good material such as
SC, CL, or CH:

SEEDING -SPECIFICATIONS
AREA TO BE SEEDED: 2.0 ACRES
USE THE SEED MIXTURE INDICATED AS FOLLOWS:
i
0.0 L{BS. FESCUE GRASS AT 60 LBS./ACRE
(BEST SUITED ON CLAYEY OR WET SOIL CONDITIONS)
SEEDING DATES: SEPTEMBER 1 TO NOVEMBER 30
FEBRUARY 1 TO MARCH 30
0.0 LBS. RYE GRAIN AT 30 LBS./ACRE (NURSERY FOR FESCUE)
0.0 LBS. 'PENSACOLA' BAHIA GRASS AT 60 LBS./ACRE
(SEE FOOTNOTE NO. 1) -
SEEDING DATES: MARCH 15 TO JUNE 15
16.0 LBS. HULLED COMMON BERMUDA GRASS AT 8 LBS./ACRE
(SUITED FOR MOST SOIL CONDITIONS)
SEEDING DATES: APRIL 1 TO DULY 31
0.0 LBS. UNHULLED COMMON BERMUDA GRASS AT 10 LBS./ACRE
at SEEDING DATES: JANUARY 1 TO MARCH 30
0.0 LBS. RYE GRASS AT 40 LBS./ACRE (TEMPORARY VEGETATION)
SEEDING DATES: DECEMBER 1 TO MARCH 30
LBS.
APPLY THEjFOLLOWING:
2000.0 ] ►BS. OF 10--10-10 FERTILIZER (1000 LBS. /ACRE)
4.0 TONS OF DOLOMITIC LIME (2 TONS/ACRE)
200.0 BALES OF SMALL GRAIN STRAW (10.0.BALES/ACRE)
ALL SURFACE DRAINS SHOULD BE INSTALLED PRIOR TO SEEDING. SHAPE
ALL DISTURBED AREA IMMEDIATELY AFTER EARTH MOVING IS COMPLETED.
APPLY LIME AND FERTILIZER THEN DISK TO PREPARE A 3 TO 4 -INCH
SMOOTH SEEDBED. APPLY SEED AND FIRM SEEDBED WITH A CULTIPACKER
OR SIMILAR EQUIPMENT. APPLY MULCH AND SECURE WITH A MULCH
ANCHORING TOOL OR NETTING.
I. PENSACOLA BAHIAGRASS IS SLOWER TO ESTABLISH THAN COMMON
BERMUDA GRASS. WHEN USING BAHIA, IT IS RECOMMENDED THAT 8
LBS./ACRE OF COMMON BERMUDA BE INCLUDED TO PROVIDE COVER
UNTIL-BAHIAGRASS IS ESTABLISHED.

4S, T
40.3
48.7e
47.78
47, 8
4B.7B
Plat of all data for the surface:
Existing
Project! KICKY EARNER SITE 8
Drawing! 4 EACH 080 PINISHiNO
Number:
Lacationt
Bid Dates
Enginsert
Owna r s
Eetimatort
Prepared bdt using Sitawark
4e.7e

tation: -45.0
45.60
48.08 ••..........
9.B "
oft
30 Mash Surface
existing
Project:
RICKY BARNES SITE a
DrawinQt
4 EACH 880 PZNISHINQ
Number:
Location:
Bid Date:
Enpinear:
Owner $
Eatimatort
Prepared
by: using Sltawcrk
Inclination: 20.0
30 Mash Surface

cz'acing to balancing within 10.0 cubic yards...
delta
r Cut I
Fill
0.00
1839 .59
18390.65
-0.00
22325.89
9897.72
-0.00
22325.88
9897.76
1.76
17586.05
20219.53
1.45
18392.66
18385.97
1.46
18390.61
18390.62
se "Proposed" by 1.46 feet.
surface called "Balanced" has been created.
Project: KICKY BARNES SITE 2
Drawing: 4 EACH 880 FINISHING
Number:
Location:
Bid Date:
Engineer:
Owner:
Estimator:
Prepared by: using Sitework
CUT -- FILL
-0.06
12428.17
12428.12
-2633.48
6.69
-0.01
c -NLS VoLUKGL baeS N oT XMCWOE A-K I
0VaQ4.cJr Aok L l Kv-9L 0 'DRA IK A4 it
h140M QpAb3.

tationt -4S.0
Rnifioaticnt 14.4 XmcUnaticns a9. B
sa. ee: l
s$. Qe..... liiiiili t
.
�a.0a
t4. 66'••...... 1 �11�i)Ii`�1`I4111't��
':5y ;�� •�,° .•iF' ems: :��; '• 7
it
ft 3D hash Surface
zr
30 Mesh Surface
Balanced
projects RICKY BARNES SITE a
Drawings 4 EACH 88O FZNXSHZNO
Humbert
Locations
Bid Date:
Engineers
Owners
Batimatort
Prepared bUs using Sltework

48.48
8
Plot of all date for the surface:
Balanced
Project,: RICKY BARNES SITE R
Drawing: 4 EACH 880 PINiBNZNQ
Number:
Location:
Bid Date:
Engineer:
Owner:
Estimator:
Prepared bu: using Sitswork

FAA W-" V
Am sR rlawc- -eft PAD
Plot of the contour data for the surface:
Belanead
Project: RICKY SARNSS SITE 2
Drawing: a BACH BBO FINISHING
Number:
Location:
aid Date:
Erng ine a r:
Owners
Estimators
Prep aevO hy: using Sitework

n? 4C.4AL CRDSs S+ S:rC0g_ VISW D_P 4 ,DMr- Z*t' Ge LA%Ofl1�
�.I`r Ric N'A RG +� DE51G-ck
t CKA9,mrs- QM - 2r v
DOTTOM or- suN%ts
DF OVYIAT g�
SI.12. isTRL bO-SAN
�-x'DR.pGE SL&V,
►�n@NT DLbC 49.74 r.TTLEb
sue. TD? o P Di kE
E b FI DOR Mlev,
J-XA-d
Pipe � i � gs34 D;�
IAGo�N Il.o -
3 5.46
w1+a-O A.PaAy �r

r
Plot of the sioPIM2 lines for the surfaces
8aiancad
Projects RICKY BARNES SITE 2
Drawing: 4 EACH 880 FINISHING
Numperi
Location:
Bid Onto:
Engineert
Owner:
Estimator:
Prepared bW: using Sitswork
48.48
a

a
51.62
61.62
61.82
m
0
o
o
z
°
z
Q
I Plot of the sloping lines for the surfocet
Balanced
Project: RICKY BARNSS SITE 2
Drawing: 4 EACH 080 FINISHING
Numbert
Location$
Bid Data$
Bnginesrt
Owner:
Hatimotort
Prepared bWt easing Sitawarrk
l . '79

4S-46
Le
- I -----j 13 JAN 98 lit XL AM

SHEET 1 OF 2
OPERATION AND MAINTENANCE PLAN
------------------------------
This lagoon is designed for waste treatment (permanent storage) and
I80 days of temporary storage. The time required for the planned
fluid level (permanent and temporary storage) to be reached may vary
due to site conditions, weather, flushing operations, and the amount
of fresh water added to the system.
The designed temporary storage consists of 180 days storage for:
11) waste from animals and (2) excess rainfall after evaporation. Also
ncluded is storage for the 25 year - 24 hour storm for the location.
The volume-ofwaste generated from a given number of animals will be
fairly constant throughout the year and from year to year, but excess
rainfall will vary fromear to year. The 25 year rainfall will not
y
be a factor to consider in an annual pumping cycle, but this storage
volume must always be available.
A maximum elevation is determined in each design to begin
pumping and this is usually the outlet invert of pipe(s) from
building(s). If the outlet pipe is not installed at the elevation to
begin pumping, a permanent marker must be installed at this elevation
to indicate when pumping should begin. An elevation must be established
to stop pumping to maintain lagoon treatment depth.
Pumping can be started or stopped at any time between these two
elevations for operating convenience as site conditions permit, such as
weather, soils, crop, and equipment in order to apply waste without
runoff or leaching.
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set,
center pivvt,guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent damage to crops.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre -
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times. When recharging is complete,
flush buildings with recycled lagoon liquid. Fresh water should not
be used for flushing after initial filling.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see attachment)
before land application.
3. Begin temporary storage pump -out of the lagoon when fluid level
reaches the elevation 49.8 as marked by permanent marker. stop pump -
out when the fluid level reaches elevation 47.6 . This temporary
storage, less'25 yr- 24 hr storm, contains 164974 cubic feet or
1234007 gallons.

SHEET 2 OF 2
�. 4. The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended maximum application rate is 0.3
inch per hour. Refer to the waste utilization plan for further details.
S. Keep'vegetation on the embankment and areas adjacent to the
lagoon mowed Ahinually. Vegetation should be fertilized as needed
to maintain a vi4brous stand.
b. Repair an, eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
outlets.
8. Keep a miAimum of 25 feet of grass vegetated buffer around
waste utilization fields adjacent to perennial streams. Waste will
not be applied in open ditches. Do not pump within 200 feet of a
residence or within 100 feet of a well. Waste shall be applied in a
manner not to'reach other property and public right-of-ways.
r
S. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.

OPERATION & NL4FVrENANCE PLAN
proper lagom &I* mm"emwt should be a year-round priority. It is especially important to
manage loveh so that you do not have problems during ceded rainy and wet periods.
Aftwmm storage capacky should be available in the lagoon for periods whey the reoeivimg crop
is dormant such as wintertime for bernmdagnass or whan there are ewtwdsd rainy spells such as
the thunderstorm season in the firm This means that at the first signs of plant growth in
the later leariY sPxiM irrigem "cording to a farm waste management plan should be
done whenever the land is dry amuo to receive lagoon liquid. This wilt make storage space
available in the lagoon for fiid= wet periods In the lste mme Mady frill the lagoon should be
pumped dow$ to the low to allow for winter storage. Every effort should be made to
mairain the lagoon close to the minimum hgWd level as long as the weather and waste utdoebon
plan will allow it_
Waiting untif the lagoon has rea&ed its mmamum. storage capacky before starting to irrigate does
not leave rgom for stoning excess water during ad nded wet periods. Overflow from the lagoon
for any reamonn vicepEt a 25-year, 24 hour storm is a violation of state law and subject to penahy
action.
LAGOON MAMENANCE
The routine ntza a of s lagoon involves the following:
✓ NIa*rntenance of a - -- —Yafor *e dim Fescue or comenm berm�udagmss are the
most common vegetative covers The vegetatim should be fertilmd each year, if needed,
to mamtak a vigorous stand. The amount of f nb1zer applied should be based on a sods
test, but in the event that it is not practical to obtain a sofls test each year, the lagoons
and siurounding area should be futi'lized with SM pounds per acre of
10-l0- I0, or equivakmt.
✓ Brush and trues on the must be controlled. This may be done by mowing,
spraying, grazing, chopping, or a combination of these practiom This should be done at
IeM once a year and possibly twice in years that weather conditions are favorable for
heavy vegetative growth.
NOTE: If vegetation is controlled by spraying, the habidde zoust not be allowed to enter the
lagoon water Such clnemicab could harm the bac u ria its the lagoon that are trwo ng the waste.

-- Mamte n ce k peetions of the enom lagoon should be made. during the initial Wmg of the lagoon
and at least monthly and after major rainfall and storm events. Items to be decked shmM
include, ss a gym, the following.
✓ Waste Inlet Pipes, Recycling Pik, and Overflow Pipes --- look for.
I . separation ofjoimts
2, cracks or breaks
3. accumulation of salts or minerals
4. overall conation ofpipes
✓ lagoon =faoe --- look for.
1. undesirable vegetative growth
2. floating or lodged debris
✓ Fanba Anent --- look for:
1. settlement, cxacidng, or "jug" holes
2. side slope stability -- shrmps our bulges
3. wet or damp areas on the back slope
4. erosion due to lack of vegetation or as a result of wave action
5. rodent damage
Larger lagoons may be surbjed to leer damage due to wave action caused by strong winds
These waves can erode the lagoon ode wall% thereby weakemmg the lagoon dam. A good stand
ofvegetatiion will rake the potential damage caused by wave actim lfvwe ac don causes
serious damage to a lagoon side wail, bales in the lagoon may be used to reduce the wave
impacts.
Any of these feamm could lead to erosion and wwkming ofthe dam. Ifyour lagoon has any of _
these features, you should call an appropriate w4wrt -bmlw with design and construction of
waste lagoons. You msy need to provide a tempmq fix if there is a threat of a waste discharge.
However, a permanent solution should be reviewed by the technical wput. Any dig into a
lagoon dam with heavy equipment is a serious undertaking with potenually serious eons Muences
and should not be conducted unless ceded by an appropriate technical expert.
Transfer Pumps -- deck for proper option of
I . recycling pumps
2. irfigafion pis
Check for Teaks, loose fittings, and overall pump operation. An anusualiy loud or grinding noise,
or a large amount of vibration, may indicate that the pump is in need or repair or replace.
NONE: Pumping systems should be inspected and operated frrequeatly caouo so that
you ire not completely "surprised" by eqm pm mt Wure. You should perform your pumping
system nwantenance at a ten; whew your lagoon is at :its low level. This will allow some safety
time should. major repairs be required. Having a nearly full lagoon is not the time to think about

.� s *Ching, repai & or borrowmg pumps. Probably, if your lagoon is fiA ya rr neighbor's lagoon
is fiM also. You should consider maiming an b vedory of spare parts or pins.
Surface waxer diversion fiatures are desiped to carry all surface drainage waters
(such as rainfall rung roof d menage, gutter outlets,, and parking lot nmoft) away
from your lagoon and other waste treatment or storage structures. The o* water
that should be coming into your lagoon is #hat wbwh comes from your flushimg
(wishing) iong) system pipes and the rainfall that hits the lagoon directly. You should
inspect your &version system for the following:
1. adequate vegetation
2. diversion capa&Y
3. ridge berm height
Identified problems should be conwed pro . It is advisable to inspect your system during or
immediately f %Hovv*g a heavy rain. If technical assistance is needed to determine proper
soWons4 consult with appropriate eVerts,
You should record the level ofthe lagoon just prior to when rain is predicted, aid then record the
level again 4 to 6 hours after the rain (asps there is no pumping). This wdl gig you an idea of
bow no& your lagoon level wdi nsee with a certain rainfall amaormt (you must also be recording
your ramp for this to work. Knowing this should heap in pig iry4ifion applications and
storage. If your lagoon rises excessively, You my have an inflow problem from a surface water
diversion or there may be seepage into the lagoon from the surrounding land.
Lagoon Operation
Surtup.
1. lnwnediately after consauc don establish a cwWlete sod cover on bare soil surfaces
to avoid CM4M
2. Fill new lagoon design treaunent volume at least halffi dl of water before waste
loading begins, taking care not to erode lining or -bank slopes.
3. Drampipes into the lagoon should have a $exrble pipe extender on the end of the
pipe to discharge near the bottom of the boon during inal filling or another
means of slowing the incoming water to avoid crosion of the lining.
4. Wken possible, begin loading new lagoons in the spring to maximize bacterial
establish(due to wasum weather).

5. It is reconmmded that a new lagoon be seeded with sludge from a healthy
working swine lagoon in the amomt of 0.25 punt ofthe fidl lagoon liquid
volume. Ibis seeding should oc;aur at least two weeks prior to the addition. of
wastewater.
6. Maintain a periodic check on the lagoon liquid pFL Ifthe pH falls below 7.0, add
apicc kural fime at the rate of I pound per limo cubic feet of lagoon liquid vohmze
until the pH rises above 7.0. Optiamm lagoon liquid pH is between 7.5 and B.O.
7. A dark color, lack of bubbling, and excessive odor sguals inadequate biological
activity. Caasuhation with a technical specialist is remmmmded if these
conditions occur for protmiged perno4 especially during the warm season.
Ltwding:
The more frequently and regularly that wastewater is added to a lagocm, the better the lagoon wM
fimcma. Mish rjacm that wash waste into the lagoon several tames daily are optm mm for
treaunent. Pit recharge systems, in which one or more buildmgs are dramel and recharged each
day, also work well.
Practice water consamdon --- m gaze building water usage and spMage from
leaking waterers, broken pipes and wash down through proper maintenance and
water Causlarnfim
himumm Ewd wastage and qnlWp by keeping feeders a4usted. This will reduce
the amount of solids antedag the lagoon
Management:
Maintain iagoo® liquid level between the pernment storage level and the full temporary
storage level.
✓ Place visible markers or stabs an the la$em bomk to show the
umunm liquid. level and the maximum liquid lever (pw' m 2-1).
✓ Start irrigating at the eadiest possible date in the spring based an undent requb memts
and sod moisture so that temporary storage wet! be mmdmiwd for the summer
season. Similarly, irrigate in the We or/mty fa[l, to provide nwmmum
lagoon storage for the wimte:r.
✓ The lagoon hgtAd level slmmM new be closer than I foot to the Invest point of the dam
or? I - I met.

-� ✓ Do not pump the lagoon liquid lcvd lower that the pernman►ent storage level unless you are
removing sludge.
✓ Locate $oat pump intakes approxmuately 18 inches i de meath the liquid surface anal as
far away from the drainpipe inlets as possible.
✓ Prevent additions of bedding Mwxials, Ira Waemmed forage or vgwtation, molded &ecl,
plastic syMes, or other foreign materials into the lagoon.
✓ Frequently remove solids from catch balms at end of confinement ]rouses or whenever they
are installed.
✓ Maintain stria vegctation, rodent, and vwmr& control near lagoon edges. Do not allow
trees or large bushes to grow on lagoon dam or umban ]unwt.
Remove sludge firm the lagoon either when the dWge storage capacity is M or before it
Us. So pe ment of the peamaman storage volmm.
✓ ffanimal production isto be termin I4 the awner is responsible for obtaining and
implementing a closure plan to eliminate, the possMit' y of a polka nt discharge.
Sludge Removal:
Rate of lagoon sludge buildup cm be reduced by.
proper lagoon sizing,
• mechanical solids separa iao offlrshed waste, gravity se Wbe offlushed waste solids in an
designed basK or
ndaimizin feed wastage and spillage.
Lagoon sludge that is removed onmwd y rather than stared long teem wW--
• have more nutrients,
• have more odor, and
• require mare land to properly use the mrtriw a
Removal techniques.
0 Nine a custom appliantor.
Mix the sludge and lagoon hgWd with a dropper -agitator impeller pump through
large -bore sprinkler nWom system onto nearby cropland; and sari incorporate.

• Dtwater the upper part of lagoon by irrigation onto nearby cropland or forage land; lnix
remaining sludge; pump into liquid sludge applicator; had and spread onto cropland or
forage land; and soul incorporate.
• llewvater the upper part of lagoon by irrigation onto nearby cropland or forage land;
dredge sludge from lagoon with drag line or shidge barge; berm an area beside lagoon to
receive the shtdge so that liquids can drain back into lagoon, allow sludge to dewater; haul
and spread with manure spreader onto cropland or forage land; and sod incorporate.
Regardless of the method, you must have the sludge material anatyed for waste coneuts just
as you would your lagoon water. The sludge wdl contain differuaut nutrient and metal values from
the liquid The application ofthe sludge to fields will be iim ited by these nutrients as well as any
previous waste applications to that field and crop requ.
When removing sludge, you mast also pay attwum to the timer to prevent damage. Close
attention by the pumper or drag-Ime operator will ensue that the lagoon liner remains intact. If
you see sod material or the synthetic liner material being disturbed, you should stop the activity
immediately and not resume until you are sure that the sludge can be removed without liner injury.
If the liner is damaged it must be repaired as soon as possible.
Sludge removed from the lagoon has a much higher phosphorus and heavy metal content than
liquid. Because ofthis it should probably be applied to land with low phosphorus and metal
IeWs, as indicated by a sod test, and inked to reduce the chance of erosion. Note that if
the sludge is applied to fields with very high so&4est phosphorus, it should be applied only at
rates equal to the aW removal ofphosphonus. As with other wastes, always have your lagoon
sludge analyzed for its ndnmt value.
The applicatio4u of shzdge will increase the amount of odor at the waste application site. Rura
precautwn should be used to observe the wind direr and other condswas whWh could
increase the concern of neighbors.
Possible Causes of Lagoon Far7nre
Lagoon failures result in the unplanned discharge ofwastewater from the structure. Types of
fits =J ude leakage through the bottom or sides, overtopping, and breach of the dam
Assuming. proper design and construction, the owner has the responarbility for enwring structure
safety. Items which may lead to lagoon fialures include:
Modification of the lagoon structure -- an example is the placemm of a pipe in
the dam without proper design and lion. (Consult an aqm t in lagoon
deign before placing any Pipes in dams)
Lagoon liquid levels --- high levels are a safety risk

Failure to inspect and maintain the dam
Excess surface water flowing into the lagoon.
Inner integrity --- protect from inlet Pipe scouring, damage dmiag sludge
removal, or rupture firm lowering lagoon liquid level below groundwater table.
NOTE: If lagoon water is allowed to overtop the dam, the moving water wM soon cause
gullies to form in the dam Once this damage smrtsy it can quickly cause a large age of
wastewater and possible dam failure.

System Calibration
Information presented in manufacturer's charts are based on average operation conditions with
relatively new equipment. Discharge rates and application rates change over lame as equipment
gets older and components wear. in particular, pump wear tends to reduce operating pressure
and flow. With continued use, nozzle wear results in an increase m the nozzle opening which
will increase the discharge rate while decreasing the wetted diameter.
You should be aware that operating the system differently than asseamed in the design will alter
the application rate, diameter of coverage, and sab�ttly the application umiformty. For
example, operating the system with excessive pressure results in smaller droplets, greater
potential far drift, and accelerates wear of the sprinkler -nozzle. Clogging of nozzles can rem*
in presaa= increm. Phrged intakes or ofmainlines will reduce operating
pressure. Operating below design pressure greatly reduces the coverage diameter and
application uniformity.
For the above reason, you should calibrate your equipment on a regular basis to ensure proper
apphcxtm rates and um6armity. Calabratiorr at least once every three years is recommended
CaMmmon involves collecting and measning flow at several locations in the application area.
Any number of containers can be used to collect flow and daermine the application raze. Rain
gauges work best because they already have a graduated scale from which to read the
application amount without having to perform addWWnal calculations. However, pans, plastic
buckets, jars, or anything with a uniform epcoing and caossrsecdon can be used provided the
liquid collected can be easily transferred to a scaled container for measuring.
For stationary sprinklers, collection containers should be located randomly throughout the
application area at several, distaaoes from sprinklers, For traveling gams, sprinklers should be
located along a transact perpendicular to the direction ofpulh. Sept out collection containers 25
feet apart along the trarrsect on both sides ofthe gun cart. You should compute the average
application rate for all nonumfutmity ofthe applicatiom On a windless day, variation between
containers of more than 30 percent is ease for cone em. You should contact your irrigation
dealer or technical specialist for assistance.
Vep *sed for Cff9#ka m Th ii ft for Opietdom of b hind Wart, Mmogemm Syatem A&n&u j

ass

• UWAmarecumMbyburrowing aatmata. trap or reamva animals and fill hates with contacted clay type
soil
• other holes may be Mmvds temporarily plugged with clay soil
Note: For pamaaent repair tsUrr K kpm probloom rye the consultation of as bffw dtml mwdenced in
their design and installation.
21 Assess the extent of the spill and ante imy u Wmm dareage.
A) Did the rcaste reach any surface waters?
B) Appmxbutely how nude was n0eased and for what dmatloo?
C) Any 4, ge noted, such as employee injury, fish kills, or property dmoge?
3) Contact appropriate age.
A) During normal business hours, call your OEM regional office a�95� hours, the sammency
number is: 914733.3 . Your photre call :houM your amae, tty. to amober. the details of
the hi p t, the oxm location of the finality, and tare locafion or direction of the qft weather and wend
aoud sous. what emogtire am a m a have been. tekm and the seriousness of the dbmdm
By U the spill lemes the property or enters sorfaeo crater, call the local EMS at III I .
C1 I avact EMS to contact the !wain Health Department at: 9L0.64t1 I7 .
D) Abe t the follow!" other agencies:
The CoopmMve Extension Service at .
Your lest Soil and Water Conservation District at
The local Natural Resolute: Conservation Service at 8 2-23 8 .
And your 1atgator at D —a 9y `0.7 y
4y prtr�#tres a: advl:ed 1+1r DEM and lure terhaicalmageWmtoreciftthedi ig.reptvi
the systet% and reassess the Waste Management Plan to keep problem with release of waste ftwn happening
NCCES. WUP werskn t - nano 1 a

Mortality NIaaa;erment -Methods
(check which methods) are being implemented)
ZL Burial three feet beneath the surface of the around within hours after
Nnowledee of the death. The burial must be at feast 100 feet from any <iowinv
stam or pubiic b reod- of water.
Rendering at a 2:tderiltQ giant IiG:!nsed undo: G.S. I06-I68.-
Camolece incinet-ul ion
:J in the ease of dead poultri only, placing in a.disposal pit of a size any: desiarl
aooroved by the Deoam-nent of—encutrur`
:1 Any method which in the professional opinion of the State Veterinarian would
mare possible the salv-ave of part of a dead animal's value without erida:ngeriMM
human or animal health. (Wricien approval of the State Vete;inanan dust oz
attac lned)

Swine Farm Waste Management Odor Control Checklist
f=ats>nsua� • 8witse p�odt>diaa Vc�va ar waQded 6>tlYa1;
R�cm�csr>tradad ben rssas�eaeeel p�radkel;
CkW ju ftxmd ape mama acne+
awfum • "Rb Cry now
$ Wale m toad aver 11"ed floors:
C1 Fcaden al bks and of'WU
0 Scram moors br MmP tism floom
a underfloor vemomion for &ft
Manus Qoa pit. • a; FcmVm nun senrm d by nub. ph mdLa%e,
• PartW mWW" du*ff*a kkm or $mpg:
O Uadaslkwr venlilaia-
aa io- ex#rwat ti-s • Vdaftgum F41i
Da11 fftiicianl prmavet
MAIM surtt U
► Dap
WaOWown between soups M
,�
O
Pad additiftg
a
Peach eram
0
Read delivery downspout axleadam to feeder
caves
Rmh taesks
• O sac ujp0011
0
FhHh ft* coven;
liquid white tseslcs am Mind
O
8xiaid tiff Ines to am bottom of laWm with
ar�s vaw
F= Wy—s
. Wft1v ►uler
f7
UndwAw A nh wilt underfloor vaacUvA a
eanvayum
pk po 1s
e A of* Glom-
a
E'mW';;aZSa lisp to out bottom of phi
lbpsld wDlta pLs aro fliiLj
wilh aetwoon teats
MANG,
• A wasp
0
Swap ma & covers
tiliiaa aa:d rfravrdm�m
0W"3zcWbcdm.
wanawatar
O
sox aov>ss
or*diaa banes
ooeivay+ns�a
AMW • Hovas *er 11, 19t Pep 3

UA S + A W�a du&&- ULMp IMk O Sump ink 90"a
a uing and draiwd""
0d o pan at • wadawater 8xtarld d1uhne pow oip4m undmadh
lopes aoaw>yme BoonUpw feral
L 1Soorl awtaap • Vd r 1�0art aapaigr;
• Hidogicd MIWWB; jecumd kgoat datap F"alurex
• ABltalioa ;K minimum %aft$ w"40-volume ratio;
Xtlgahawa sglWion whoa puarpin8;
O lrtachw al aaalioa;
13 Pmvm WabShal addltivaa
lrri8alioq W • H lrroft at dry days with awe w to wkd;
"Otda• Wht4 drill 1�I10iroers nronnnatdad aparatln� prr•eadura:
Pomp bt ko MW Ingo= Opw Swfw ;
0 Pump from aocoa"U" 6NUM
O Flak ra Mad am m haw pipet at and o/
� P�kBa
17aad ardrnaio • C:arrata Proper ditian of Banc asiao
16ws wawr WKga • Orade wd ludacapa aardr that WOW dMIso
radlitia • A+ t4wQOwwdioa of away from 1'adlklob
ordwb rruttar
traalaa Gt0j= on mmb Feat arx'm road rnal *mw
roads horn farm man
AddWwal Wa Wlw AvailaWa Fron :
Cattle we arrmtt;NCSU, Connly Ea"Sion Cen
Dairy 8drmiarai Uri Marwro M ut 3ya m • Ldca Wheala ,Rood Fuld I.a oWwy ; ERAS 709-91. NMU - RAE
Up= Dap and Mr oat for Livaank Mom Dammm and Swap; WAS 103413 NCSU - SAE
Manapruaat of Dairy Wuwwow ; 88AB IM83 NCSU - SAE
Cw bra ba or Maauro and Wav aW Applim" Egrtipaw ; BU B Pats Shot NCSU - BA B
Nalco a Co w m In Aalrool Manure ldwtaqunant: Odan sad N ; P1t4107. 1"S Conference Pmeecdinp Florida Coapemi•e 6xleaMon
A MOO' Novembar t I,1W PW 2

p#*d'0"1'll N•D...jV
1)
tpd fm&lpp ualiaa om oleo al adad
13
eye
:aid FgfR al *mares J° fRAWWo 5"PhwO
q
a •M!!!Pemwmm
saaa*wp aomrodrqlradad
• rlruNr
"arplxo A nP4WP* 140M WMM
Cl
.Vtgkp mdu Jai mAwl wmjpo upp u! pauS
D
,IN It uliwm tmm
O
so A gang
�q�+p pHU �h g
=%RWA#jrojo a1o4q MS
Q
%% La sad a
M"xo ao xmllppr P*Ift 4 *ad
O
'am mil* morAdr u" UUN=1"Nom %am
L]
p "uw=d ppgol► . q
'mmspglAm o Iles
0
• m r'a
4mnbs mm palun aeouag
p
hq�idms u Y •
!la"R
•iulll� olt+la►:lW •
poll mpn"m x adplup * paalxs
p
:+Mlp l • SM "PR
q=Mxo.0$NN pe 1pllblvf9 umwd
D
boa vft
G
mil! GRRK gtlNW • axJna
fts" 1Axlpluj Jo UMQU
©
• ,a
woSg $**room mo dam
D
'amstud S<rpaeado � �l�lW �J'
iINP pu1M • pp�ou
:prga► ep so a� �� � iGP � �W I
C�
lmopq� omseaat �lH • �1+4� ��l�I
mMqppu Iolol4 mwd CI
wom um P*m mW D
!alP, *Mph-04m air wflu 4w,a' ao} !y
'4P")* " Val Adad 'r ward A • am UDO%l
l�►al p1�I! I0=14mim Wan
p� Flo al>nq p 8 O XOMMA fnreeP y I,is �o
raspasad aUjm s ails "DO slmlalm a; tam ash aaipog

.•
meta
tatd Waftwe web Ihst water
fa�itks . Mk" deeorspasltioa of away 11" tLaa'"
or�nle tnaaar
Ma rweG3a oato • 1404 am coeds Fsao loom cad mslnlemraee
alb goads Alm am
Amu
S"w hadoc" Pkrm PokWW Odor &w= rd RamWks ; BUM FICt Shot
SWw bo&Wiat Faclliq Mum meat: Pit Recitsrpe - Lwn Trutmt ; SM 1"
SWw Pra*wtlaa FwAby 1Mamwe Wisawmat Uaderiloor Flush - LAso r 71rea nal ; WAR 1T9-iS
Oesia and ii►lunmeal for t iwstocA Megan Thatmw end Stoup; WAS 103413
C oMmake of Mrw a gad Wastewater App*Ww 8golpment ; W" Fact abed
CorMroliltty Oder 8om Was NuAdkw ; PM43
ldavkQnM d Aasararsca Progam; Ni'l'C MMW
Opikm for Maass Odor; a repel Aew the Swim Odor TWk Forte
Nulu tca Coaoerrar to AWma1 Mswwe hkaWmaw Odws mad Filar; PRO107,1"S Caafaam Peoeaed up
Avsbbk From
NCSU - SAE
NCSU - BAB
NCSU -13AG
NM - GAS
NC KI - GAS
NCSU - SwiW Farterrdan
NC Pork hoduaers Assoc
NCSU ASri CommurAc tions
FtwW4 Cooperative 6xtensiaa
A&=- WWAVAM 11,1"GO Pea S

t WM 'gal 'II Jg1=WAPN-.. _NV
jvw"
n slow pvV ponom adtos mg d1 ipps
panpnmtxra do xeauq to awmu pus � 1oad�al 13
tom imp* pw via* icu UK moo'
4.2.0 p"Imm owbopa 19"Awd MMw
o* wo Aga abdpw fmj=w Aq am
PUN""* a" avI"ow
1nPJIM Agp Ot ti Ott &pW PAMq Atp
01 • L "fv) 9P4 wqV= o uo dq O UM 13
'*o) nuwfj paai u +p pm mwdo tom p
�a� �aq ea a�8pa tea► tuop
la�l OiAjA sR]� f0 YOjlflRflR'�
MAWd q =mvpwd dny xW pw s000M WAD
jo oxnq loop 104=2 aupnIM qww a do" ighroor a rea
'anjjftJo %K WAOaMA-wo ate! 0
go m of pwwb 4 ftwom pod
� *POo• �� ��R v�oeao� �
'pap is s�opns
uia�:per pa�nga�oao 000mo� e! �InaWlli� .
=otltjedo loWv Jo; islMnq:) loj;uo:) io®sul

Aa�cnawlatiaas oif an lmd wastes C! 131iminsts !aw am that tnp molrtnre slanS
Am fad wastage fences and other locatio"s where wage
scamsolstes and 40rbasa by aduds h
minimal
D Molataia face rows ad f iita strtm around
mAsW holdLaS own to ndnknlw
mcw wbstkm dwasles (ire.. Wspm Wr and
momm a break up aoasaralated sodas as
Dry Arumi a Hawdhog • Ac umlatiom of amoral wages d Remove ~ on s reaft buffs (e.g.. 7 - 10
SySMms day intarval durlktS nnaner;15.10 day interval
daring wWa) *two mama. la loaded far h
appkW= or diapoal.
L3 Provide for adegwta dnsltsap asowrd mamm
IkKk011a
D lmW4 for end snows or break up sc amulalad
wastes is [Ater sidps wound *4pda and
manure hudft areas as needed.
For maws Wonhalas aontacl the Coapaa kv Baum&* Servkk Depa rlso kt of Batomolagy, Bolt 7613, Not CaooiiON State Usiversky.
Rmlclgh. NC, 276W7613.
A M!C - NovarAm 11.1"fi. P6ga 2

RECEIVED
WATER QUALITY SECTION
MAR 9 01999
SPECIFICATIONS FOR THE LAND APPLICATI(YM�f `t TER
IRRIGATION SYSTEM FOR BARNES FARMS INC.
3520 HEAD FEEDER TO FINISH FARM
COLUMBUS COUNTY, FACILITY NUMBER 24-107
TELEPHONE: [phone]
Introduction
This plan presents calculations and procedures for the proper application of wastewater
based on crop parameters, soil conditions and equipment constraints. Mr. Barnes's swine
farm is a 3520 head facility that has already been certified by a technical specialist. This
facility produces approximately 8,160 lbs of plant available nitrogen annually. The irrigation
system will have to pump approximately 3,256,000 gallons of effluent per year (dependent
upon waste analysis) to apply the nitrogen produced. Mr. Barnes has an existing irrigation
system onsite. This system consists of an AG -RAIN model 33A hard hose traveler and a
PACO model 15-40157 engine driven pump with a 15-inch impeller.
Acreage Calculations
The wetted acreage was calculated for each travel lane shown on the map. Acreage
determinations were made according to standards developed by the Biological & Agricultural
Engineering Department at NCSU. The travel lanes were categorized as exterior, interior, or
as a single lane. Tables included with this plan were used to calculate the start end and stop
end acreage of each pull.
Agronomic Information
Currently, Mr. Barnes has a good stand of coastal Bermuda hay overseeded with a winter
annual. The soil types present on this farm according to the Columbus County Soil Survey
include Torhunta, Stallings, Norfolk, Foreston, Butters and Goldsboro. On the areas covered
by lanes 1-2, Butters was used as the primary soil type. Stallings was the primary soil on
lanes 3-5 and Norfolk was primary to lanes 6-8.
System Operation
The AMADAS Traveler is equipped with a Nelson SR 150 gun. It is recommended that
this gun be operated with a 1.18-inch ring nozzle at a 225-degree are at 70-psi pressure at the
gun. Permanent start and stop markers shall be placed in the field. Hydrants were
installed prior to this procedure and do not signify a stop pull mark. The system should
not be operated in winds greater than 5 mph.

Barnes Farms Inc. Facility Number 24-107
Columbus County December 28 1998
At the beginning of a travel lane, the sprinkler cart should be left stationary for a period of
approximately 15 to 20 minutes to a,?ply wastewater to the beginning of the pull, but never
long enough to have any runoff.. :The same procedure should be followed when the cart
reaches the end of the pull. Once again, no runoff should occur. During these operations, the
operator should carefully monitor field conditions. With experience, it will be easier to
determine the exact amount of stationary time to be used at the beginning and end of travel
lanes. Calculations included in this plan give a good estimate of the time required for each
pull to be completed. Each application of wastewater should be limited to a maximum depth
of 0.5 inches and a maximum frequency of no more than once every 2 days. It is
recommended that a flow meter be installed at the pump station so that the operator can
determine the total volume of wastewater applied at each irrigation event. If this is not
possible, the total operation time of the system must be recorded so the total volume of waste
applied can be computed.
Svstem Maintenance
During freezing weather there should be no land application of waste and the pump and
above ground portions of the discharge and suction pipes should be drained. Hydrants
should be drained to approximately one foot below the ground surface. The simplest way to
drain these pipes is to install a drain valve at the low point in the pipe. Precautions should be
taken to make sure wastewater does not drain to streams or ditches.
Air relief/vacuum relief valves should be checked at least two times a year to ensure they
are operating properly.
The traveler should be properly operated and maintained as recommended by the
manufacturer. The speed compensation should be checked regularly to ensure wastewater is
being applied at proper rates. The traveler should be washed down at least once per year to
reduce corrosion. If the pump is disconnected from the ground entry pipe, both the end of
the ground entry and the end of the pump should be covered to prevent the entrance of
foreign material into the system. The system should be checked for leaks during each
operation. Any leaks should be repaired immediately. The traveler should be sheltered when
not in use to prevent damage to the hose from sunlight.
Record Keeping and System Operation Evaluation
Accurate records should be maintained on all land application of wastewater. The two
forms IRR-1 and IRR-2 contained in the Certification Training for Operators of Animal
Waste Management Systems Manual are excellent for this use. They allow the operator to
record when the system was operated, the length of time and the amount of effluent applied.
These records which include pumping and lagoon level records which are required for
permitted farms need to be maintained for five years. Senate Bill 1217 also requires that the
soil be sampled annually and lagoon effluent be analyzed within 60 days of application. It is
suggested that the lagoon be sampled quarterly.
2

Barnes Farms Inc. Facility Number 24-107
Columbus County December 28, 1998
The irrigation system should be operated in daylight hours and in conditions where wind
speeds are less than 5 mph. Each time the system is operated the operator should check for
leaks, malfunctioning sprinklers or an� other things that might affect system uniformity. The
system should not be operated during freezing weather. The pump and gun require little
maintenance except for draining the pump during freezing weather and checking the
sprinkler for nozzle wear and proper rotation. If the pump has a packing seal it may need to
be adjusted so that leakage is not excessive. The leakage should be piped back to the lagoon.
There should be a pressure gauge at the pump, one at the reel, and one on the sprinkler in
the field_ This will allow the operator to ensure there is adequate pressure on the sprinkler in
the field.
There is also a requirement that an Emergency Action Plan (EAP) be prepared for the
farm. Details of the EAP are given in Chapter 5, of the Certification Training for Operators
of Animal Waste Management Systems Manual. The plan deals with lagoon overflow,
runoff from waste application fields, leakage from the waste distribution system and leakage
from the base or side walls of the lagoon. All of the items in the EAP are common sense
things to do if there is a problem. All farm workers need to be familiar with the plan and
how to respond if an emergency occurs.
Each farm will receive two inspections per year, one compliance inspection from the
Division of Water Quality (DWQ), and one operational review from the NC Division of Soil
and Water Conservation (DSWC). Both inspections will use the same forms. Items that are
not in compliance with the Waste Management Plan can be cited as violations. It is
important that the Waste Management Plan be implemented and followed.
The system should be evaluated annually using the procedures developed by specialists at
NCSU. The evaluation brochures are available through the local North Carolina Cooperative .
Extension Service Office.
If there are any questions or comments regarding the design of this irrigation system
please contact Jamie Revels of the Division of Soil & Water Conservation Fayetteville
Regional Office [phone] or Brian Gannon of the Division of Soil & Water
Conservation Wilmington Regional Office [phone].
3

91 1
Off'
KIM
a

. - -,._a - -_• psi c .'. , d,,,� .'•t� p, i�'"�y
" _ 7 - 0 .ts } ,'�`�d �� �:'� . }ram .,�,•��.-r r�'�'� � ,-.
� f+. �'' ",.. - '�. +` - I ✓ �� C. �r r� �:-v -a Wy'- � �' - -ice
all -t
Zy
-�
Lo
51
�`-,;. - _ �. " `- � f - •ice � - ',,-' • ' � � .-
.6..M __fie
''�• - •.1 - jam'' -:�. � �
Oil

�H CARIREUGAIM
s
BY31EIMMESMNER�j S
0225 s JJ
F Q� al3
Name: RAMIE E REVELS
Company: DIVISION OF SOIL & WATER CONSERVATION %��q �'•••••''• �0,�'�
Address: 22_5 GREEN STREET, SUITE 604 LE FAYETTEVILNC 28301 '�� '� GP�`'``
1r,-J1
Phone: T91%486-1541 - ..�_. 7.�a^
REQUIRED DOCUMENTATION
The following details of design and materials must accompany all irrigation designs:
1. A scale drawing of the proposed Irrigation system which includes hydrant local ons-travel lanes, pipeline routes thrust block
locations and buffer areas where applicable.
2. Assumptions and computatioris for determining total dynamic head and horsepower requirements.
3. Computations used to' determine all mainline and lateral pipe sizes.
4. Sources andlor calculations used for determining applicatian.raies.
5. Computations used to; determine the size of thrust blocks and illustrations of all thrust block configurations required in the system.
6. Manufacturer's specifications for the irrigation'. pump, traveler.arid sprinklers).
7. Manufacturer's -specifications for the irrigation pipe and/or USDA-NRCS standard for irrigation Water Conveyance,
N.C. Field Office Technical Guide, Section IV, Practice Code 430-DD.
8. The information required by this form are the minimurn requirements. It Is the responsibility of the
designer to consider all relevant factors at a particular site and address there as appropriate.
9. Irrigation pipes should not be. Installed In lagoon or storage pond embankments without the approval
of the designer.
NOTE: A buffer strip 50 feet wide or wider must be maintained between the limits of the irrigation system and all perennial
streams and surface waters per DEHNR-DWQ Code Section 15A NCAC 28'0200-Waste Not Discharged to Surface
Waters.

IRRIGATION SYSTEM DESIGN PARAMETERS
Landowner/Operator Name: Ricky Barnes County: Columbus-
Facility Numbers: 4-107 Date: _12-15-98
Address: 3965 Konas Cross Road
Lumberton. NC 28358
Telephone: [phone]
Table 9-
FIELD SPECIFICATIONS
Tract Number
Field Number
Line Number
Approximate
Maximum
Usable Size
of Field
acres
Soil Type
Slope
%
Crops
Maximum
Application
Rate
inlhr
Maximum
Application
per Irrigation
cycle
inches
Cycles Per Year
estimated
T1687, Field 3, Pull 1
5.26
Butters
0-2
Coastal Bermuda Hay Overseeded
0.45
0.50
9-10 cycles per year
T1687, ield 3, Pull 2
4.37
Butters
0-2
Coastal Bermuda Hay Overseeded
0.45
0.50
9-10 cycles per year
T1687, Field 1, Pull 3
4.52
Stallings
0-2
Coastal Bermuda Hay Overseeded
0.50
0.50
9-10 cycles per year
T1687, Field 1, Pull 4
3,24
Stallings
0-2
Coastal Bermuda Hay Overseeded
0.5o
0.50
9-10 cycles per year
T1687, Field 1, Pull 5
2.50
Stallings
0-2
Coastal Bermuda Hay Overseeded
0.50
0.50
9-10 cycles per year
T1687, Field 4, Pull 6
2.15
Norfolk
0-2
Coastal Bermuda Hay Overseeded
0.50
0.50
10-11 cycles per year
T1687, Field 4, Pull 7
2.74
Norfolk
0-2
Coastal Bermuda Hay Overseeded
0.50
0.50
10-11 cycles per year
T1687, Field 4, Pull 8
3.12
Norfolk
0-2
Coastal Bermuda Hay Overseeded
0.50
0.50
10-11 cycles per year

IRRIGATION SYSTEM DESIGN PARAMETERS
Landowner/Operator Name:
I I . 1] T OaIor,ra WESi���
Telephone: [phone],158
Table 'I -
FIELD SPECIFICATIONS
County:. Qplumbus
Date: _ 12-15-98
Tract Number
Field Number
Line Number
Approximate
Maximum
Usable Size
of Field
acres
Soil Tvoe
Slope
%
Crops
Maximum
Application
Rate
inlhr
Maximum
• Application
per Irrigation
cycle
inches
Cycles Per Year
estimated
T1687, Field 3, Pull 1
5.26
Butters
0-2
Coastal Bermuda Hay Overseeded
0.45
0.50
9-10 cycles per year
T1687, Field 3, Pull 2
4.37
Butters
0-2
Coastal Bermuda Hay Overseeded
0.45
0,50
9-10 cycles per year
T1687, Field 1, Pull 3
4.52
Stallings
0-2
Coastal Bermuda Hay Overseeded
0.50
0.50
9.10 cycles per year
T1687, Field 1, Pull 4
3.24
Stallings
0-2
Coastal Bermuda Hay Overseeded
0.50
0.50
9-10 cycles per year
T1687, Field 1, Pull 5
2.50
Stallings
0-2
Coastal Bermuda Hay Overseeded
0.50
0.50
9-10 cycles per year
T1687, Field 4, Pull 6
2.15
Norfolk
0-2
Coastal Bermuda Hay Overseeded
0.50
0.50
10-11 cycles per year
T1687, Field 4, Pull 7
2.74
Norfolk
0-2
Coastal Bermuda Hay Overseeded
0.50
0.50
10-11 cycles per year
T1687, Field 4, Pull 8
3.12
Norfolk
0-2
Coastal Bermuda Hay Overseeded
0.50
0.50
10-11 cycles per year

TABLE 2- TRAVELING IRRIGATION GUN SETTINGS
Barnes Farms Inc., Ricky Barnes, Owner DWQ 1D No. 24-107
3965 Kings Cross Road, Lumberton NC 28358
Columbus County [phone]
Make Model & Type of E ui ment: AG -RAIN Model 33A with Nelson SR150 gun with 225 degree arc and i.18" Ring Nozzle
Tract No.,
Field No.
&
Line No.
Traveling Gun
Speed (filmin)
Application
Rate
(inlhr)
Travel Lane
Effective Effective
width (ft.) Length (ft.)
wetted
Diameter
(feet)
Equipment Setting
Nozzle Operating Operating
Diameter Pressure Pressure
(in.) @ Gun (psi) @ Reel (psi)
Annual Operation Time (minutes)
Time Cycles Total
Required per Operating
Per Pull Year Time
T1687, Field 3, Pull 1
3.80
0.67
252.5
907.4
297
1.18
70
101
228
10
2280
T1687, Field 3, Pull 2
3.80
0.67
252.5
753.9
297
1.18
70
101
188
10
1880
T1687, Field 1, Pull 3
3.80
0.67
252.5
779.8
297
1.18
70
101
195
10
1950
T1687, Field 1, Pull
3.80
0.67
208.0
678.5
297
1.18
70
101
175
10
1750
T1687, Field 1, Pull 5
3.80
0.67
252.5
431.3
297
1.18
70
101
103
10
1030
T1687, Field 4, Pull 6
3.80
0.67
267.3
350.4
297
1.18
70
101
87
11
957
T1687. Field 4, Pull 7
3.80
0.67
252.5
472.7
297
1.18
70
101
114
11
1254
T1687, Rej 4, Pull 8
3.80
0.67
252.5
538.2
297
1.18
70
101
131
11
1441
209 hours

TABLE 2- TRAVELING IRRIGATION GUN SETTINGS
Barnes Farms Inc., Ricky Barnes, Owner DWQ ID No. 24-107
3965 Kings Cross Road, Lumberton NC 28358
Columbus County [phone]
Make Model & Type of Equipment: AG -RAIN Model 33A with Nelson SR150 gun with 225 degree arc and 1.18" Ring Nozzle
Tract No.,
Field No.
&
Line No.
Traveling Gun
Speed (ft/min)
Application
Rate
(inlhr)
Travel Lane
Effective Effective
Width (ft.) Length (ft.)
Wetted
diameter
(feet)
Equipment Setting
Nozzle Operating Operating
Diameter Pressure Pressure
(in.) @ Gun (pal) Reel (psi)
Annual Operation Time (minutes)
Time Cycles Total
Required per Operating
Per Pull Year Time
T1687, Field 3, Pull 1
3.80
0.67
262.5
907.4
297
1.18
70
i01
228
10
2280
T1687, Field 3, Pull 2
3.80
0.67
252.5
753.9
297
1.18
70
101
188
10
1880
T1687, Field 1, Pull 3
3.80
0.67
252.5
779.8
297
1.18
70
101
195
10
1950
T1687, Field 1, Pull 4
3.80
0.67
208.0
678.5
297
1.18
70
101
175
10
1750
T1687, Field 1, Pull 5
3.80
0.67
252.5
431.3
297
1.18
70
101
103
10
1030
T1687, Field 4, Pull 6
3.80
0.67
267.3
350.4
297
1.18
70
101
87
11
957
T1687, Field 4, Pull 7
3,80
0.67
252.5
472.7
297
1.18
70
101
114
11
1254
T1687, Fiel 4, Pull
3.80
0.67
252.5
538.2
297
1A8
70
101
131
11
1441
209 hours

IRRIGATION SYSTEM DESIGN PARAMETERS
Landowner/Operator Name: Ricky Ilarnea-
Facility Numbers: DWQ ID no. 24-107
Address: _ 3965 Kbgs Cross
Table 1-
Lumberton, NQ 28355
Telephone:
f a 141[ [ON61
County: Columbus
Date: 12-15-98 _
Tract Number
Field Number
Line Number
Approximate
Maximum
Usable Size
of Field
{acres
Soil Type
Slope
%
Crops
Maximum
Application
Rate
in/hr
Maximum
Application
per Irrigation
cycle
inches
Cycles Per Year
estimated
T1687, Field 3, Pull 1
5.26
Butters
0-2
Coastal Bermuda Hay Overseeded
0.45
0.50
9-10 cycles per year
T1687 field 3, Pull 2
4.37
Butters
0-2
Coastal Bermuda Hay Overseeded
0,45
0.50
9-10 cycles per year
T1687, Field 1, Pull 3
4.52
Stallings
0-2
Coastal Bermuda Hay Overseeded .
0.50
0.50
9.10 cycles per year
T1687, Field 1, Pull 4
3.24
Stallings
0-2
Coastal Bermuda Hay Overseeded
0.50
0.50
9-10 cycles per year
T1687, Field 1, Pull 5
2.50
Stallings
0-2
Coastal Bermuda Hay Overseoded
0.50
0.50
9-10 cycles per year
T1687, Field 4, Pull 6
2.15
Norfolk
0-2
Coastal Bermuda Hay Overseeded
0,50
0.50
10-11 cycles per year
T1687, Field 4, Pull 7
2.74
Norfolk
0-2
Coastal Bermuda Hay Overseeded
0.50
0,50
10-11 cycles per year
T1687. Field 4, Pull 8
3.12
Norfolk
0-2
Coastal Bermuda Hay Overseeded
0,50
0.50
10-11 cycles per year

Table 3- IRRIGATION SYSTEM SPECIFICATIONS
Barnes Farms Inc., Ricky Barnes, Owner DWQ ID No. 24-107
3965 Kings Cross Road, Lumberton NC 28358
Columbus County [phone]
Traveling
Irrigation Gun
Flow Rate of Sprinkler ( m)
245
Operating Pressure at Pump (psi)
119
Design Precipitation Rate (in/hr)
0.67
Hose Length (feet)
800
Type of Speed Compensation
Mechanical
Pump Type (PTO, Engine, Electric)
Engine
Pump Power Requirement, (h
48
Engine Horsepower @ 75% eff.
1 64
Table 4- THRUST BLOCK SPECIFICATIONS
FOR 6-INCH SUPPLY LINE
Location
5 uare Feet
90 Degree Bend
7.3
45 Degree Bend
4.0
Dead End
2.8
Gate Valve
2.8
Tee or HydrantHydrantl
2.8
11'

POWER
.. ■■■TI�r�■I,I�r!�■�►1\► ■/�►� Arks!%►■■1
r■■//t/1������ �!�a'■�!%/:rill.//:i:t'�■■1
■■■II ■��SI ■ 1►.a■/:cam!/►.�Z�slr r��l
tj�"WndPP4..aAM I LE mmum
■
■
1 }1L]

--Specifications-
33A PERFORMANCE GUIDE
(02) 33A X 800' WATER -REEL PERFORMANCE
Inches Depth of Application
320-
Nelson
Sprinkler
System
"Irrigated
Travel Speed - Feet Per Hour
SR15D
Performance
Inlet
AREA
I'Mcip
40
50
75
100
125
1 150
250
480
3 NCZ:
PSI GPM i DIA
PSI
Width X Length
1 Rate
1.08"
6D
182
300
87
210 X 905
1.8
1.5
1.0
0.7
0.6
0.5
0.3
0.2
0.34
Ring
70
197
310
100
217 X 909
1.9
1.5
1.0
0.8
0.6
0.5
0.3
0.2
0.34
or
60
210
320
112
224 X 912
2.0
1.6
1.1
0.8
0.6
0.5
0.3
0.2
0.34
Taper
90
223
1330
125
231 X 916
2.0
1.6
1.1
0.8
0.7
0.5 .
0.3
0.2
0.34
1.18'
50
205
311a
I 81
210 X 995
2.1
1.6
1.1
0.8
0.7
0.5
0.3
0.2
0.31
Ring
60
ZZ5
315
95
Z21 X 910
2.1
1.7
1.1
0.9
0.7
0.5
0.3
D.2
0.38
or 1.0"
70
245
330
110
231 X 916
2.2
1.8
1.2
0.9
0.7
0.6
0.4
0.2
0.38
Taper
80
260
340
123
238 X 919
2.3
1.8
1.2
0.9
0.7
0.6
0.4
0:2
0.38
1.25"
50
255
320
92
224 X 912
2.4
1.9
1.3
1.0
0.8
0.6
0.4
0.2
0.42
Ring
60
275
335
197
235 X 917
2.5
2.0
1.3
1.0
6.0
0.7
0.4
0.2
0.41
or 1.1"
70
295
350
iZ2
245 X 923
2.5
2.0
1.4
1.0
0.8
0.7
0.4
0.3
0.41
Taper
80
315
360
138
252 X 926
2.5
2.1
1.4
1.1
0.8
0.7
0.4
0.3
0.41
1.34"
50
300
335
1D3
235 X 917
2.7
2.2
1.4
1.1
0.9
0.7
0.4
0.3
6.45
Ring
60
330
350
122
245 X 923
2.8
2.3
1.5
1.1
0.9
0.8
0.5
0.3
0,45
or 1.2"
7D
355
365
139
256 X 928
2.9
2.3
1.6
1.2
0.9
0.8
0.5
0.3
0.45
Taper
80
380
380
157
266 X 933
3.0
2.4
1.6
1.2
1.0
0.8
0.5
0.3
0.44
1.41"
50
350
360
118
252 X 926
2.9
2.3
1.6
1.2
0.9
0.8
0.5
0.3
0.46
Ring
60
335
375
139
263 X 931
3.1
2.5
1.6
1.2
1.0
0.8
0.5
D.3
0.46
at 1.3"
Taper
Hours Far 800 Feet of Travel:
2D.D
16.D
t0.7
B.D
fi.4
5.3
3.2
2.0
System inlet pressure shown above is for Turbine Drives. Engine Drives will be approx 10 PSI lower
-Area covered may vary depending on wind conditions, field dimensions and use of
unspecified sprinklers. The average area covered per run is 5 acres.
The precipitation rate is in inches per hour and is based on a sprinkler arc of 320 degrees.
The 'System Inlet Pressure' is the pressure required at the traveler inlet. It includes
allowances for the traveler plumbing and drive, PE tube and sprinkler pressure.
It does not include any pressure allowances for field elevation or mainline
pressure loss.
IMPORTANT! Turbine drives will have higher pressure losses at higher RPM
and are not recommended for travel speeds above 250 feet per hour.
For speeds above 250 Ft. per hour use an Engine Drive.
Follow the belt pulley selections below.
Lowest speed pulleys: Up to 75 feet per hour.
Medium speed pulleys: From 75 to 125 feet per hour.
Highest speed pulleys: From 125 to 250 feet per hour.
NOTE: Specifications are subject to change without notice.
(D2)397-013a.0
43

Standard Features ��pecfa anceInformationN��>
Fiy ' aft _ ;°Aeies.wl.1
3dial Inflow Turbine - The heart
ut the drive system. This extremely
efficient turbine motor delivers quiet,
smooth, continuous power.
• Automatic Shutdown for the
turbine motor.
• Heavy Duty Chassis and frame.
• Retraction Speed Indicator.
• Pressure Gauge.
• Infinitely Adjustable Speed
Ranges.
• Speed Compensator.
• Miswrap Safety Stop.
• PTO Rewind and Drive Shaft.
• Gun Cart with adjustable wheel
width.
• Hose Guide to insure proper
packing of hose.
• Ball Bearing Turntable.
• Nelson Slow Reverse Gun.
dun Cart Lift.
Stabilizer Legs - Heavy Duty.
Crank down..
• Supply Hose 4 in x 30 ft. with 4
in. male ring lock coupler on inlet
end.
f•�
Made m U S A
Ask about additional
Water -Feels® for
smaller areas.
'Width is based on 70% of the wetted diameter
ModaEt ZT40A; �kT37A`�T33AF T30A
;aafdt
PE�U6 CIk xr rz^ $ 0
se�sge s1� 3aaoo
IfL w`CBiBiitf7� ± f err i-. 'Q1:Ft - .
'�5peed=Hae9eiftJhr}r� ::* SG300• � 4�,'i00 40-200 � �40.200 . .
`a ;'17L�[15/'x �_2SLarFS err-@'1ZLirlar '111.�t15
10-0 t0-0
Note: t40A%137A'w/vwlfeels 8'� aided" �''
Polyethelene Tube - Only PE tube designed and
constructed for the constant coiling and dragging is
considered for use on Ag-Rain Water -Reels. The tubing is
backed by a 5-year pro -rated warranty.
PE Tube Repair - A simple "screw -in" mender is available for
repairing the PE tube should it become damaged for any
reason.
t
707 S. Schrader Ave., P.O. Box 290, Havana, IL 62644.
Phone [phone] FAX [phone]
B - um of contusuaq pmd= y a�ems- ;�np:o9 d ==chins in Ws IeaAet r'�ay not oe xaendGal to ciweni nraaUC�w1. TTT zerormarce inlpma5pn m bus leans is oasea an res13 C9na .40 under a aaniCuiaf set 01 conGuons. 4C:u3i
field oeft—arce may vam from Inls ama ceaeM,nq an'+in8a%e IZRLrtslances of facie. place. v aInet. i1 a pIagement and :7er 1w.cm. and unces are sunleC.:a G once '�cj: -aYe.
GK9610WR-D

CERTIFIED WASTE MANAGEMENT PLAN
WETTABLE ACRES WORKSHEET
Farm Name: Barnes Farms Inc.
Manager or Producer Ricky Barnes
Technical Specialist: Jamie Revels
Facility Contact: Sonya Johnson
Mailing Address: 3965 Kings Cross Road
Facility Number: 24-107
Phone Number:—910)-739-0158
Phone Number: (910)-486-1541
Phone Number: _ • 910Z645-6758
Lumberton, NC 28358 Columbus Comly
Was farm sited for animals prior to 10/1/95:
If No, date farm sited for animals:
Irrigation System Tvype
(check all that apply)
Stationary sprinkler with permanent pipe Center -pivot system
Stationary sprinkler with portable pipe Linear -move system
Stationary gun with permanent pipe X Hose drag traveler
Stationary gun with portable pipe
Acres calculated should correspond to that shown in the Waste Utilization Plan
and Form IRR-2.
To the best of my knowledge, this worksheet(s) and map(s) provides an accurate
representation of the system used to irrigate the animal waste generated by this operation.
5 ,4 /Lt.,2� 1 ZLI I
Signature (Manager or Producer) Date

CAWMP HARD -HOSE TRAVELER FIELD DATA SHEET
1. Make and model number ; SAG -RAIN MODEL 3 3 A WITH ENGINE DRIVE
2. Hose length and hose inside diameter. (ID) 800 feet & 3.3-inch inside diameter hose.
3. Gun make and model number NELSON SR 150 with 24 de-pree trajectory
4. Gun nozzle size 1.18-inch . X ring orifice, taper bore orifice.
5. Hydrant spacing vanes feet. Indicate whether uniform, X random.
Number of exterior lanes 6 Interior lanes 1 Single lanes 1
**6. Operating pressure at hose reel 101 psi.
observed at working gauge. provided by owner. X computation
7. Gun wetted diameter -297 feet .
measured X 90% of mfg. table value
8. Gun pressure 70 psi.
observed at working gauge, X determined from gun charts.
"1**9. Supply line size 6-inch (from pump to last hydrant).
** 10. Supply line length 1280 feet (maximum pumping distance)
** I l . Supply line type X PVC, aluminum.
** 12. Pump make and model number PACO pump cat.# 15-40157 with 15-inch impeller ,
* * 13. Pump capacity, 245 gpm.
** 14. Engine make and model number _ _ _ , or
**15. Electric motor horsepower and rpm hp rpm
ote: It is strongly recommended that operating pressure at the reel and gun wetted
diameter be field determined.
Locate each hydrant on a copy of the map. Indicate the start and stop of the sprinkler cart
for each travel lane and show distance traveled. Also indicate the normal arc angle of the
gun for each pull through a field. Show the location of the supply line. Irrigated acres will
be determined by travel lane.
** Optional data, furnish where possible.
*** Information furnished by
and/or / "
Signature of Owner or Facility Representative Signature of Technical Specialist
and/or Jamie Revels
Printed Name of Owner or Facility Representative Printed Name of Technical Specialist
Date2 -023--� Date
*** Only the person or persons collecting the data should sign the data sheet.

CAWMP WETTABLE ACRE COMPUTATIONAL WORKSHEET
1. Farm Number (Identification) 24-107 Field Number (Identification) T1687 Pull # 1 .
2. Irrigation System Designation X Existing Irrigation System
New / Expanded Irrigation System
.v
3. Type of Irrigation System Stationary Sprinkler X Hard Hose Traveler
Center Pivot Linear Move System
4. Number of Stationary Sprinklers # Interior Sprinklers # Exterior Sprinklers
Number of Travel Lanes # Single Lanes # Interior Lanes I # Exterior Lanes
5. Wetted Diameter 297 [feet] 90% of mfg. table value !L4B-_ Length of Pull [feet]
6. Spacing 208 Lane Spacing [feet] 70% [as percentage of wetted diameter]
Sprinkler spacing along lateral [feet] [as percentage of wetted diameter]
7. Sprinkler or Hydrant Layout X Multiple Laterals / Hydrants
Single Lateral / Hydrant Excessively spaced Sprinklers / Hydrants
8. Read the irrigated area per sprinkler / travel pull for the given wetted diameter from the appropriate table
and column based on pattern, spacing, and sprinkler / travel lane location.
Stationary Sprinklers
Acres per Interior Sprinkler from Table Column
Acres per Exterior Sprinkler from Table Column
Traveler: Interior Hydrant (travel lane)
(a) Acres start end of pull Table EI70 Column B
(b) Acres middle portion of pull
{Pull length (feet] X Wetted Width [feet]] / 43560
(c) Acres stop end of pull from Table E170 Column D
Total acres for Interior Pull (Sum: a + b + c)
Traveler: Exterior Hydrant (travel lane)
0?l'4 (a) Acres start end of pull Table EE70 Column B
4.3'7 (b) Acres middle portion of pull
(Pull length 151f [feet] X Wetted Width a5a•[feet]) / 43560
Oo 15 (c) Acres stop end of pull from Table EE70 Column D
-U Total acres for Exterior Pull (Suns: a + b + c)
Traveler: Single Hydrant (travel lane)
(a) Acres start end of pull Table E90+ Column B
(b) Acres middle portion of pull
0.9* {Pull length [feet] X Wetted Width [feet]} / 43560
(c) Acres stop end of pull from Table E90+ Column D
Total acres for Single Pull (Sum: a + b + c)
9. Multiply the tabulated acreage value per sprinkler or travel pull by the number of sprinklers or pulls
Of each category in the field. Sum all of these and this is the total irrigated acreage for the field.
(a) Acres per Interior Sprinkler or Pull X # Sprinklers or Pulls = Acres
5,310 (b) Acres per Exterior Sprinkler or Pull X �_ # Sprinklers or Pulls = 5• 3-' Acres
(c) Acres per Single Sprinkler or Pull X # Sprinklers or Pulls = Acres
Total Wettable Acres for Field (Sum: 9a + 9b + 9c)
Wettable Acre Computational Worksheet Completed by: �S CS, &W_Z.-L
Date: XR-da- P5 .

CAWMP WETTABLE ACRE COMPUTATIONAL WORKSHEET
1. Farm Number (Identification) 24-107 - Field Number (Identification) T1687 Pull # a .
2. Irrigation System Designation X Existing Irrigation System
New / Expanded Irrigation System
v
3. Type of Irrigation System
4. Number of Stationary Sprinklers
Number of Travel Lanes
Stationary Sprinkler X Hard Hose Traveler
Center Pivot Linear Move System
# Interior Sprinklers # Exterior Sprinklers
# Single Lanes # Interior Lanes # Exterior Lanes
5. Wetted Diameter 297 [feet] 90% of mfg. table value GOO Length of Pull [feet]
6. Spacing 208 Lane Spacing [feet] 70% [as percentage of wetted diameter]
Sprinkler spacing along lateral [feet] [as percentage of wetted diameter]
7. Sprinkler or Hydrant Layout X Multiple Laterals / Hydrants
Single Lateral / Hydrant Excessively spaced Sprinklers / Hydrants
8. Read the irrigated area per sprinkler / travel pull for the given wetted diameter from the appropriate table
and column based on pattern, spacing, and sprinkler / travel lane location.
Stationary Sprinklers
Acres per Interior Sprinkler from Table Column
Acres per Exterior Sprinkler from Table Column.
Traveler: Interior Hydrant (travel lane)
(a) Acres start end of pull Table EI70 Column B
(b) Acres middle portion of pull
{Pull length [feet] X Wetted Width [feet]} / 43560
(c) Acres stop end of pull from Table EI70 Column D
Total acres for Interior Pull (Sum: a + b + c)
Traveler: Exterior Hydrant (travel lane)
0.111(a) Acres start end of pull Table EE70 Column B
V (b) Acres middle portion of pull
{Pull length EM [feet] X Wetted Width � .[feet]) / 43560
G�lS (c) Acres stop end of pull from - Table EE70 Column D
L}.317 Total acres for Exterior Pull (Sum: a + b + c)
Traveler: Single Hydrant (travel lane)
(a) Acres start end of pull Table E90+ Column B
(b) Acres middle portion of pull
0.9* {Pull length [feet] X Wetted Width [feet]} / 43560
(c) Acres stop end of pull from Table E90+ Column D
Total acres for Single Pull (Sum: a + b + c)
9. Multiply the tabulated acreage value per sprinkler or travel pull by the number of sprinklers or pulls
Of each category in the field. Sum all of these and this is the total irrigated acreage for the field.
(a) Acres per Interior Sprinkler or Pull X # Sprinklers or Pulls = Acres
`Z (b) Acres per Exterior Sprinkler or Pull X 1 # Sprinklers or Pulls = 3� Acres
(c) Acres per Single Sprinkler or Pull X # Sprinklers or Pulls = Acres
Total Wettable Acres for Field (Sum: 9a + 9b + 9c) p�3
Wettable Acre Computational Worksheet Completed by: JC�'m iC f 1CVO-15 Date: Id, n

CAWMP WETTABLE ACRE COMPUTATIONAL WORKSHEET
1. Farm Number (Identification) 24-107 Field Number (Identification) T1687 Pull # 3.
2. Irrigation System Designation X Existing Irrigation System
New / Expanded Irrigation System
3. Type of Irrigation System Stationary Sprinkler X Hard Hose Traveler
Center Pivot Linear Move System
4. Number of Stationary Sprinklers # Interior Sprinklers # Exterior Sprinklers
Number of Travel Lanes # Single Lanes # Interior Lanes �� # Exterior Lanes
5. Wetted Diameter 297 [feet] 90% of mfg. table value ra G Length of Pull [feet]
6. Spacing 208 Lane Spacing [feet] 701/o [as percentage of wetted diameter]
Sprinkler spacing along lateral [feet] [as percentage of wetted diameter]
7. Sprinkler or Hydrant.Layout X Multiple Laterals / Hydrants
Single Lateral / Hydrant Excessively spaced Sprinklers / Hydrants
Read the irrigated area per sprinkler / travel pull for the given wetted diameter from the appropriate table
and column based on pattern, spacing, and sprinkler / travel lane location.
Stationary Sprinklers
Acres per Interior Sprinkler from Table
Column
Acres per Exterior Sprinkler from Table
Column
Traveler: Interior Hydrant (travel lane)
(a) Acres start end of pull Table
EI70 Column B
(b) Acres middle portion of pull
{Pull length [feet] X Wetted Width [feet]) / 43560
(c) Acres stop end of pull from Table
EI70 Column D
Total acres for Interior Pull (Sum: a + b + c)
Traveler: Exterior Hydrant (travel lane)
0. (a) Acres start end of pull Table
EE70 Column B
3.G 33 (b) Acres middle portion of pull
{Pull length 6a 6 [feet] X Wetted Width a5a-S [feet]) / 43560
QJS (c) Acres stop end of pull from Table
EE70 Column D
Total acres for Exterior Pull (Sum: a + b + c)
Traveler: Single Hydrant (travel lane)
(a) Acres start end of pull Table
E90+ Column B
(b) Acres middle portion of pull
0.9* {Pull length [feet] X Wetted Width [feet]} / 43560
(c) Acres stop end of pull from Table E90+, Column D
Total acres for Single Pull (Sum: a + b + c)
9. MultipIy the tabulated acreage value per sprinkler or travel pull by the number of sprinklers or pulls
Of each category in the field. Sum all of these and this is the total irrigated acreage for the field.
(a) Acres per Interior Sprinkler or Pull X # Sprinklers or Pulls = Acres
4.5 a (b) Acres per Exterior Sprinkler or Pull X # Sprinklers or Pulls = y Sd Acres
(c) Acres per Single Sprinkler or Pull X # Sprinklers or Pulls = Acres
Total Wettable Acres for Field (Sum: 9a + 9b + 9c)
Wettable Acre Computational Worksheet Completed by: J4m;P-&,T Date: /2~R?- /o

CAWMP WETTABLE ACRE COMPUTATIONAL WORKSHEET
1. Farm Number (Identification) 24-107 Field Number (Identification) T1687 Pull #' ' .
2. Irrigation System Designation X Existing Irrigation System
New / Expanded Irrigation System
.v
3. Type of Irrigation System
Stationary Sprinkler X Hard Hose Traveler
Center Pivot Linear Move System
4. Number of Stationary Sprinklers # Interior Sprinklers 9 Exterior Sprinklers
Number of Travel Lanes # Single Lanes / # Interior Lanes # Exterior Lanes
5. Wetted Diameter 297 [feet] 90% of mfg. table value Sao Length of Pull [feet]
6. Spacing 208 Lane Spacing [feet] 70% [as percentage of wetted diameter]
Sprinkler spacing along lateral [feet] [as percentage of wetted diameter]
7. Sprinkler or Hydrant Layout X Multiple Laterals / Hydrants
Single Lateral / Hydrant Excessively spaced Sprinklers / Hydrants
8. Read the irrigated area per sprinkler / travel pull for the given wetted diameter from the appropriate table
and column based on pattern, spacing, and sprinkler / travel lane location.
Stationary Sprinklers
Acres per Interior Sprinkler from Table Column
Acres per Exterior Sprinkler from Table Column
Traveler: Interior Hydrant (travel lane)
0. E6 (a) Acres start end of pull Table EI70 Column B
(b) Acres middle portion of pull
{Pull length Sao [feet] X Wetted Width a43 [feet]} / 43560
0. (0 (c) Acres stop end of pull from Table E170 Column D
3*a"t Total acres for Interior Pull (Sum: a + b + c)
Traveler: Exterior Hydrant (travel lane)
(a) Acres start end of pull Table EE70 Column B
(b) Acres middle portion of pull
{Pull length [feet] X Wetted Width [feet]} / 43560
(c) Acres stop end of pull from Table EE70 Column D
Total acres for Exterior Pull (Sum: a + b + c)
Traveler: Single Hydrant (travel lane)
(a) Acres start end of pull Table E90+ Column B
(b) Acres middle portion of pull
0.9* {Pull length [feet] X Wetted Width [feet]} / 43560
(c) Acres stop end of pull from Table E90+ Column D
Total acres for Single Pull (Sum: a + b + c)
9. Multiply the tabulated acreage value per sprinkler or travel pull by the number of sprinklers or pulls
Of each category in the field. Sum all of these and this is the total irrigated acreage for the field.
(a) Acres per Interior Sprinkler or Pull X # Sprinklers or Pulls = 3. ;�f Acres
(b) Acres per Exterior Sprinkler or Pull X # Sprinklers or Pulls = Acres
(c) Acres per Single Sprinkler or Pull X # Sprinklers or Pulls = Acres
3. ow- „ Total Wettable Acres for Field (Sum: 9a + 9b + 9c)
Wettable Acre Computational Worksheet Completed by: J^rrr?IQ heels Date: ld-oe— & .

CAWMP WETTABLE ACRE COMPUTATIONAL WORKSHEET
1. Farm Number (Identification) 24-107 Field Number (Identification) T1687 Pull # S .
2. Irrigation System Designation X Existing Irrigation System
New / Expanded Irrigation System
3. Type of Irrigation System
4. Number of Stationary Sprinklers
Number of Travel Lanes
5. Wetted Diameter
Stationary Sprinkler X Hard Hose Traveler
Center Pivot Linear Move System
# Interior Sprinklers # Exterior Sprinklers
# Single Lanes # Interior Lanes / # Exterior Lanes
297 [feet] 90% of mfg. table value R ?*2 S Length of Pull [feet]
6. Spacing 208 Lane Spacing [feet] 70% [as percentage of wetted diameter]
Sprinkler spacing -along lateral [feet] [as percentage of wetted diameter]
7. Sprinkler or Hydrant Layout X Multiple Laterals / Hydrants
Single Lateral / Hydrant Excessively spaced Sprinklers / Hydrants
Read the irrigated area per sprinkler / travel pull for the given wetted diameter from the appropriate table
and column based on pattern, spacing, and sprinkler / travel lane location.
Stationary Sprinklers
Acres per Interior Sprinkler from Table Column
Acres per Exterior Sprinkler from Table Column
Traveler: Interior Hydrant (travel lane)
(a) Acres start end of pull Table E170 Column B
(b) Acres middle portion of pull
{Pull length [feet] X Wetted Width [feet]) / 43560
(c) Acres stop end of pull from Table E170 Column D
Total acres for Interior Pull (Sum: a + b + c)
Traveler: Exterior Hydrant (travel lane)
0. �7JL (a) Acres start end of pull Table EE70 Column B
/oF/ (b) Acres middle portion of pull
{Pull length a78 [feet] X Wetted Width 25Rd.5 [feet]) / 43560
08 (c) Acres stop end of pull from Table EE70 Column D
R. 50 Total acres for Exterior Pull (Sum: a + b + c)
Traveler: Single Hydrant (travel lane)
(a) Acres start end of pull Table E90+ Column B
(b) Acres middle portion of pull
0.9* (Pull length [feet] X Wetted Width [feet]) / 43560
(c) Acres stop end of pull from Table E90+ Column D
Total acres for Single Pull (Sum: a + b + c)
9. Multiply the tabulated acreage value per sprinkler or travel pull by the number of sprinklers or pulls
Of each category in the field. Sum all of these and this is the total irrigated acreage for the field.
(a) Acres per Interior Sprinkler or Pull X # Sprinklers or Pulls = Acres
-�,50 (b) Acres per Exterior Sprinkler or Pull X / # Sprinklers or Pulls = 9,,50 Acres
(c) Acres per Single Sprinkler or Pull X # Sprinklers or Pulls = Acres
a- SO Total Wettable Acres for Field (Sum: 9a + 9b + 9c)
Wettable Acre Computational Worksheet Completed by: J iF �CZP Date: 42—d?- IR -

CAWMP WETTABLE ACRE COMPUTATIONAL WORKSHEET
1_ Farm Number (Identification) 24-107 Field Number (Identification) T1687 Pull #ro .
2. Irrigation System Designation X Existing Irrigation System
New / Expanded Irrigation System
3. Type of Irrigation System Stationary Sprinkler X Hard Hose Traveler
Center Pivot Linear Move System
4. Number of Stationary Sprinklers # Interior Sprinklers # Exterior Sprinklers
Number of Travel Lanes 1 9 Single Lanes # Interior Lanes # Exterior Lanes
5. Wetted Diameter 297 [feet] 90% of mfg. table value V'7 Length of Pull [feet]
6. Spacing 208 Lane Spacing [feet] 70% [as percentage of wetted diameter]
Sprinkler spacing along lateral [feet] [as percentage of wetted diameter]
7. Sprinkler or Hydrant Layout X Multiple Laterals / Hydrants
Single Lateral I Hydrant Excessively spaced Sprinklers I Hydrants
8. Read the irrigated area per sprinkler / travel pull for the given wetted diameter from the appropriate table
and column based on pattern, spacing, and sprinkler / travel lane location.
Stationary Sprinklers
Acres per Interior Sprinkler from Table Column
Acres per Exterior Sprinkler from Table Column
Traveler: Interior Hydrant (travel lane)
(a) Acres start end of pull Table EI70 Column B
(b) Acres middle portion of pull
(Pull length [feet] X Wetted Width [feet]] / 43560
(c) Acres stop end of pull from Table EI70 Column D
Total acres for Interior Pull (Sum: a + b + c)
Traveler: Exterior Hydrant (travel lane)
(a) Acres start end of pull Table EE70 Column B
(b) Acres middle portion of pull
(Pull length [feet] X Wetted Width [feet] / 43560
(c) Acres stop end of pull from Table EE70 Column D
Total acres for Exterior Pull (Sum: a + b + c)
Traveler: Single Hydrant (travel lane)
0, GG(a) Acres start end of pull Table E90+ Column B
, 7 (b) Acres middle portion of pull
0.9* (Pull length 91 � [feet] X Wetted Width a9 [feet]} / 43560
0.16 (c) Acres stop end of pull from Table E90+ Column D
1/57 Total acres for Single Pull (Sum: a + b + c)
9. Multiply the tabulated acreage value per sprinkler or travel pull by the number of sprinklers or pulls
Of each category in the field. Sum all of these and this is the total irrigated acreage for the field.
(a) Acres per Interior Sprinkler or Pull X # Sprinklers or Pulls = Acres
(b) Acres per Exterior Sprinkler or Pull X # Sprinklers or Pulls = Acres
a. (c) Acres per Single Sprinkler or Pull X # Sprinklers or Pulls = Acres
a./5 Total Wettable Acres for Field (Sum: 9a + 9b + 9c)
Wettable Acre Computational Worksheet Completed by: �r�m.,'P �rlij Date: %"o71S--9

CAWMP WETTABLE ACRE COMPUTATIONAL WORKSHEET
1. Farm Number (Identification) 24-107 Field Number (Identification) T1687 Pull # 7 .
2. Irrigation System Designation X Existing Irrigation System
New / Expanded Irrigation System
3. Type of Irrigation System
Stationary Sprinkler X Hard Hose Traveler
Center Pivot Linear Move System
4. Number of Stationary Sprinklers # Interior Sprinklers 9 Exterior Sprinklers
Number of Travel Lanes # Single Lanes # Interior Lanes # Exterior Lanes
5. Wetted Diameter
297 [feet] 90% of mfg. table value 3QO_ Length of Pull [feet]
6. Spacing 208 Lane Spacing [feet] 70% [as percentage of wetted diameter]
Sprinkler spacing -along lateral [feet] [as percentage of wetted diameter]
7. Sprinkler or Hydrant Layout X Multiple Laterals / Hydrants
Single Lateral / Hydrant Excessively spaced Sprinklers / Hydrants
Read the irrigated area per sprinkler / travel pull for the given wetted diameter from the appropriate table
and column based on_pattern, spacing, and sprinkler / travel lane location.
Stationary Sprinklers
Acres per Interior Sprinkler from Table
Column
Acres per Exterior Sprinkler from Table
Column
Traveler: Interior Hydrant (travel lane)
(a) Acres start end of pull Table
EI70 Column B
(b) Acres middle portion of pull
(Pull length (feet] X Wetted Width [feet]} / 43560
(c) Acres stop end of pull from Table
E170 Column D
Total acres for Interior Pull (Sum: a + b + c)
Traveler: Exterior Hydrant (travel lane)
004 (a) Acres start end of pull Table
EE70 Column B
1257 (b) Acres middle portion of pull
(Pull length 39,0 [feet] X Wetted Width 050.5 [feet]} / 43560
06/5 (c) Acres stop end of pull from Table
EE70 Column D
61,174 Total acres for Exterior Pull (Sum: a + b + c)
Traveler: Single Hydrant (travel lane)
(a) Acres start end of pull Table
E90+ Column B
(b) Acres middle portion of pull
0.9* {Pull length [feet] X Wetted Width [feet]} / 43560
(c) Acres stop end of pull from' Table E90+ Column D
Total acres for Single Pull (Sum: a + b + c)
9. Multiply the tabulated acreage value per sprinkler or travel pull by the number of sprinklers or pulls
Of each category in the field. Sum all of these and this is the total irrigated acreage for the field.
(a) Acres per Interior Sprinkler or Pull X # Sprinklers or Pulls = Acres
(b) Acres per Exterior Sprinkler or Pull X # Sprinklers or Pulls = Acres
(c) Acres per Single Sprinkler or Pull X # Sprinklers or Pulls = Acres
J. o '7i Total Wettable Acres for Field (Sum: 9a + 9b + 9c)
Wettable Acre Computational Worksheet Completed by: �� _; o / `yN,iS Date:QP
.

CAWMP WETTABLE ACRE COMPUTATIONAL WORKSHEET
1. Farm Number (Identification) 24-107 Field Number (Identification) T1687 Pull # .
2. Irrigation System Designation X Existing Irrigation System
New / Expanded Irrigation System
3. Type of Irrigation System
4. Number of Stationary Sprinklers
Number of Travel Lanes
5. Wetted Diameter
Stationary Sprinkler X Hard Hose Traveler
Center Pivot Linear Move System
# Interior Sprinklers # Exterior Sprinklers
# Single Lanes # Interior Lanes f # Exterior Lanes
297 [feet] 90% of mfg. table value . 3? S7 Length of Pull [feet]
6. Spacing 208 Lane Spacing [feet] 70% [as percentage of wetted diameter]
Sprinkler spacing along lateral [feet] [as percentage of wetted diameter]
7. Sprinkler or Hydrant Layout X Multiple Laterals / Hydrants
Single Lateral / Hydrant Excessively spaced Sprinklers / Hydrants
S. Read the irrigated area per sprinkler / travel pull for the given wetted diameter from the appropriate table
and column based on pattern, spacing, and sprinkler / travel lane location.
Stationary Sprinklers
Acres per Interior Sprinkler from Table Column
Acres per Exterior Sprinkler from Table Column
Traveler: Interior Hydrant (travel lane)
(a) Acres start end of pull Table E170 Column B
(b) Acres middle portion of pull
(Pull length [feet] X Wetted Width [feet]} / 43560
(c) Acres stop end of pull from Table EI70 Column D
Total acres for Interior Pull (Sum: a + b + c)
Traveler: Exterior Hydrant (travel lane)
0." (a) Acres start end of pull Table EE70 Column B
`3� (b) Acres middle portion of pull
]Pull length 3'V [feet] X Wetted Width RW. [feet]} / 43560
0,15 (c) Acres stop end of pull from Table EE70 Column -D
3. I3, Total acres for Exterior Pull (Sum: a + b + c)
Traveler: Single Hydrant (travel lane)
(a) Acres start end of pull Table E90+ Column 'B
(b) Acres middle portion of pull
09*{Pull length [feet] X Wetted Width [feet]) / 43560
(c) Acres stop end of pull from Table E90+ Column D .
Total acres for Single Pull (Sum: a + b + c)
9. Multiply the tabulated acreage value per sprinkler or travel pull by the number of sprinklers or pulls
Of each category in the field. Sum all of these and this is the total irrigated acreage for the field.
(a) Acres per Interior Sprinkler or Pull X # Sprinklers or Pulls = Acres
_ (b) Acres per Exterior Sprinkler or Pull X #Sprinklers or Pulls = 3/7 Acres
(c) Acres per Single Sprinkler or Pull X # Sprinklers or Pulls = Acres
Total Wettable Acres for Field (Sum: 9a + 9b + 9c)
Wettable Acre Computational Worksheet Completed by: Tamo'e O 1,2: Date: w2—v -- y?

Table E90+. Area Allowances for Existing Hard Hose Traveler Systems
Field with Single Pull or Multiple pulls and
Hydrant Spacing Greater than 90 percent of verified wetted diameter,
(Areas shown are acreage petside starting/stopping gun location)
wetted start end Stop end wetted area, acres
diameter wetted
d area arc angle arc angle arc angle arc angle arc angle
feet: acres 180 degrees 225 degrees 270 degrees 315 degrees 330 degrees
(B) (C) (o) (E) (F) (G)
-150
0.16
0.00
0.04
0.08
0.12
0.14
160
0.19
0.00
0.05
0.09
0.14
0.16
170
021
0.00
0.05
0.11
0.16
0.18
.180
024
0.00
0.06
0.12
0.18
0.20
190
0.26
0.00
0.07
0.13
0.20
0.22
200
029
0.00
0.07
0.15
0.22
0.24
210
0.322
0.00
0.08
0.16
0.24
0.27
220
0.35
0.00
0.09
0.18
0.27
0.29
230
0.39
0.00 •
0.10
0.19
0.29
0.32
240
0.42
0.00
0.11
0.21
-0.32
0.35
250
0.46
0.00
0.11
0.23
0.34
0.38
260
0.49
0.00
0.12
0.25
0.37
0.41
270
0.53
0.00
0.13
0.27
0.40
0.44
280
0.57
0.00
0.14
0.29
0.43
0.48
290
0.61
0.00
0.15
0.31
0.46
0.51
300
0.66
0.00
0.16
0.33
0.49
0.55
310
0.70
0.00
0.18
0.35
0.53
0.58
320
0.75
0.00
0.19
0.37
0.56
0.62
330
0.80
0.00
0.20
0.40
0.60
0.66
340
0.84
0.00
0.21
0.42
0.63
0.70
350
0.89
0.00
0.22
0.45
0.67
0.75
360
0.95
0.00
0.24
0.47
0.71
0.79
370
1.00
0.00
0.25
0.50
0.75
0.83
380
1.05
0.00
0.26
0.53
0.79
0.88
390
1.11
0.00
0.28
0.56
0.83
0.93
400
1.17
0.00
0.29
0.58
0.88
0.97
410
1.23
0.00
0.31
0.61
0.92
1.02
420
1.29
0.00
0.32
0.64
0.97
1.07
430
1.35
0.00
0.34
0.68
1.01
1.13
440
1.41
0.00
0.35
0.71
1.06
1.18
450
1.48
0.00
0.37
0.74
1.11
123
460
1.55
0.00
0.39
0.77
1.16
1.29
.470
1.61
0.00
0.40
0.81
1.21
1.34
480
1.68
0.00
0.42
0.84
1.26
1.40
490
1.75
0.00
0.44
0.88
1.32
1.46
• 500
1.83
0.00
0.46
0.91
1.37
1.52
Page 26

Table EE70. Area Allowances -for Existing Hard Hose Traveler Systems
Exterior lane - in field with multiple overlapping lanes:
Hydrant_ Spacing based on 7i�
r ;percent of verified wetted diameter,
(Areas . shown are acreage outside starting/stopping gun location)
wetted start end Stop end wetted area, acres
diameter _--wetted
d area arc angle arc angle are angle arc angle arc angle
feet-, acres .-180 degrees 225 degrees 270 degrees 315 degrees 330 degrees
(a). (C) (D) (E) (17 (G)
150
0.18
0.00
0.04
0.08
0.13
0.15
160
021
0.00
0.04
0.09
0.15
0.17
170
024
0.00
0.05
0.11
0.17
0.19
160
026
0.00
0.06
0.12
0.19
0.22
190
0.29
0.00
0.06
0.13
0.21
0.24
200
0.33
0.00
0.07
0.15
024
0.27
210
0.36
0.00
0.08
0.16
0.26
0.29
220
0.40
0.00
0.08
0.18
0.29
0.32
230
0.43
0.00
0.09
0.19
- 0.31
0.35
240
0.47
0.00
0.10
0.21
0.34
0.38
250
0.51
0.00
0.11
0.23
0.37
0.42
260
0.55
0.12
0.25
0.40
0.45
270
0.60
_0.00
0.00
0.12
0.27
0.43
0.49
280
0.64
0.00
0.13
0.29
0.46
0.52
290
0.69
0.00
0.14
0.31
0.50
0.56
300
0.74
0.00
0.15
0.33
0.53
0.60
310
0.78
0.00
0.16
0.35
0.57
0.64
320
0.84
0.00
0.18
0.37
0.61
0.68
330
0.89
0.00
0.19
{ 0.40
0.64
0.73
340
0.94
0.00
0.20
0.42
0.68
0.77
350
1.00
0.00
0.21
0.45
0.72
0.82
360
- 1.06
0.00
0.22
0.47
0.77
0.86
370
1.12
0.00
0.23
0.50
0.81
0.91
380
1.18
0.00
0.25
0.53
0.85
0.96
390
1.24
0.00
0.26
0.56
0.90
1.01
400
1.31
0.00
0.27
0.59
0.95
1.07
410.
1.37
0.00
0.29
0.62
0.99
1.12
420
1.44
0.00
0.30
0.65
1.04
1.18
430
1.51
0.00
0.32
0.68
1.09
1.23
440
1.58
0.00
0.33
0.71
1.14
1.29
450
1.65
0.00
0.35
0.74
1.20
1.35
460
1.73
0.00
0.36
0.77
1.25
1.41
470
1.80
0.00
0.38
0.81
1.31
1.47
480
1.88
0.00 '
0.39
0.84
1.36
1.54
490
1.96
0.00
0.41
0.88
1.42
1.60
500
2.04
0.00
0.43
0.91
1.48
1.67
Page 14

Table EI70. Area Allowances for Existing Hard Hose Traveler Systems
Interior lane - in field with multiple overlapping lanes:
Hydrant Spacing based on 70percent of verified wetted diameter,
(Areas shown are acreage outside - starting/stopping gun location)
wetted start end Stop end wetted area, acres
diameter .... -wetted
d area arc angle arc angle are angle arc angle arrc angle
feet acres _ .180 degrees 225.degrees 270 degrees 315 degrees 330 degrees
(B) (C) P) (E) (F) (G)
150
0.16
0.00
0.03
0.06
0.11
0.13
160
0.19
0.00
0.03
0.07
0.13
0.15
170
0.21
0.00
0.03
0.08
0.15
0.17
180
0.24
0.00
0.04
0.09
0.16
0.19
190
0.26
0.00
0.04
0.10
0.18
0.21
200
0.29
0.00
0.05
0.11
0.20
0.23
210
0.32
0.00
0.05
0.12
0.22
0.26
220
0.35
0.00
0.06
0.14
0.25
0.28
230
0.39
0.00
0.06
0.15
_ 0.27
0.31
240
0.42
0.00
0.07
0.16
0.29
0.34
250
0.46
0.00
0.07
0.18
0.32
0.36
.260
0.49
0.00
0.08
0.19
0.34
0.39
270
0.53
0.00
0.08
0.20
0.37
0.42
280
0.57
0.00
0.09
0.22
0.40
0.46
290
0.62
0.00
0.10
0.24
0.43
0.49
300
0.66
0.00
0.10
0.25
0.46
0.52
310
0.70
0.00
0.11
0.27
0.49
0.56
320
0.75
0.00
0.12
0.29
0.52
0.60
330
0.80
0.00
0.13
0.31
0.55
0.63
340
0.85
0.00
0.13
0.32
0.59
0.67
350
0.90
0.00
0.14
0.34
0.62
0.71
360
0.95
0.00
0.15
0.36
0.66
0.75
370
1.00
0.00
0.16
0.38
0.69
0.80
380
1.06
0.00
0.17
0.41
0.73
0.84
390
1.11
0.00
0.18
0.43
0.77
0.88
400
1.17
0.00
0.19
0.45
0.81
0.93
410
1.23
0.00
0.20
0.47
0.85
0.98
420
1.29
0.00
0.21
0.50
0.89
1.03
430
1.35
0.00
0.22
0.52
0.94
1.08
440
1.42
0.00
023
0.54
0.98
1.13
450
1.48
0.00
0.24
0.57
1.03
1.18
460
1.55
o.00
0.25
0.59
1.07
1.23
470
1.62
0.00
0.26
0.62
1.12
1.28
480
1.69
0.00
0.27
0.65
1.17
1.34
490
1.76
0.00
0.28
0.68
1.22
1.40
500
1.83
0.00
0.29
0.70
1.27
1.45
Page 21

Worksheet for Calculating Amount of
Swine Finishing Lagoon Liquid
The amount ,of: liquid to be irrigated from swine finishing production farm primary
anaerobic lagoons can be estimated by the following method. The amount is dependent
on'the amount of fresh water used; lagoon size, surface area and sealing; and local climate.
a. Number of animals production facility capacity:
b. Days per year animals in production facility-:
C. Average -pounds live weight per animal:
d. Lagoon liquid surplus
manure and urine
excess fresh water :
lagoon surface rain surplus :
total :
e. Total farm lagoon liquid surplus
no. animals (a) x gals/hd/year (d)
L Divide gallons by 27154 to get acre -inches
gals/year (e) Y ' 27154
TYPICAL ACTUAL
1000 353.0
333 333
13 5 135-
-gals/head/year
450
300 3 jo
175 05
925 / j
gals/year-
9z5eoa 3j;%j Doc
acre inches/yearn
34 �ay.
!3 �D. S ir,��3) _ �'a 165 N x /;0'
leo
CS.16 5A) ++ _ a' 5 /6, A/
GCTe-InCq .
/0 7 �VAO
NCSUINCCES Nutrient Management Manua! —Reference Section
23

RQ► o M ock/ 3 3 /q
of ko y. ru : '/i 3. 3 �� d
/nelson SR /:�0 Cry.-,, �Y° 7�� . , aa5 0.4 re
&to/#GO/ 330
ul37 ' U
6 `� su p/ / ►� cv:� y'� �r4rs a/� ;n,s/A,OveQD2
�/E�
Py
w•// 6e
CQ%ez
us%A3
r7-QWOc/5
��.>•, �UCC'�S P -.
4�1C•Q
�'�» �rri
4��e�
�'�9�
�ferrr„n�'�+�
)r• GUQ3 7(04lcrl°�' A
�0� cry m.
/, #Q� -03; -0S �#7, 4S
Td/e ,EE 7o
5-fQr4 end cup ffnp-G�
3-Io f e n ar cc1a��{Q o� Q crQ s
mickj/e 5EC40,;
0. VV
4rC, ifl%
GoacAc►,s-
5Y k ( /'Y?. 0*) Y. 0,4.,� �r
dull a
600 '
k �� s f �o � --� 3. 3 Al�oas O. W Y. 3 7 o4cit�;
Pcc—.3
-' x- (i p. s f i09) 3. C- 3 14crQs o. c-2
�f. 5a Ac•�a
L{l/ Yf
a7 1 X
�f �Ii � A 1/ XCA � ✓.7� -
r�. Ji� �^i"�
L �
3, G X
> /. SS xC� s
335 ` k
3 /0 f G. s 3 =
3. /,;Z Aeea ;

Aoj)T
_�-. �►��� � gill -� � ,
2
Fr 0rn 7Q 6/Q F _r 7d'
zil4e� end is th of 4cx-s Ace
>51'op eno4 cp,*d 4C Yes Ala
&/l � L sg O' x a CF' -- a •itS -/ o. �.0 = 3. Acmes
ate'°Arc
F"ri,
-end O-ce >
e» 0. /C 08 02
5�0�o d c�-�f�.d Qe►e,�
Pul/ 6 a/�,x 0.r(a4>)
T�/Q/ 40eAd
x9r000m/401
Ae onlo e r, op at-)
3 3 Ac►�s -/ 0. as = a, 15 Acyes
/Qnc� w/r c Q-4,10n 4po-4' ,,s
GV V 4 Gu; Yrjl`Y- Q) I q av
5A?/i,h9s R�4E = s,-
No,-poll( R YE = s / Gt se 5.5
Tom. n
YE �. o
3 /V /&I Al
3�5
163 A) � ^ `l.'18 � r or
�s i6a �. P
ezema -,►x=ti

UQQ r1(C'S /�-�ri�'�
s. Sr' .
�
Use3�4
5, $ Tons 50 16s N ; a75 iGs 5-0 ti
sl cye To Q
3as I6,� AJ
ece .)6 ;ncles pc°�` yQor• or: Qpp/cQ�'on.s 0 S��,j;,.
n1
C+CYe -in c
Soy'/ T
AJO
00
0.
Gt►e-i4.G� r
T N fro Pn CIs Pit//
P� t� a Y 3 � R it 3a5- % _ a�. as i6� At
Pu tl .� �, 5a � -k 3a5 f4-1N = / '� 65 /6s ti
#
35'5--
1J53 A
- 7o-a.s 14 i Al
R
— ?V&
/�3 A/
7� Q &5 T
-a/ I/ �6s Al

1)
' Cv
b
Qz
Q
L
L
1
o
4�C
+C4-
A
O
�1
� A
n
Y
u
Fy
U,
`
p
C
'�
U
h
•
`
C)
4aVIM
_ry
_
IZ�

�p
O
Imo}
\",
N
Q
k
4
M
4�
Z-
n
t�
0
h
Iti
II
� �
v
ti
�
M
ll
��
M
�
n
�

I,D�I oolcG��; o�
Fh1'c4on L 0 6Li -/
a.3 5C
L�f�1,e oY1 S P 5c
Sphi hk1er,
p;Pe.; tip. Psi
To _ /i 3 jo s
p4�
P S.ES Ps<
4r- 3�p� •
o4Q/
Q = 3.3
la9of o-' 6'1'
fSH P = Q4-
39 60 -t F-P
F-P - 0. 35

Try-i�Q f»r? r%gr-,7
5DPC
A ij27,5
�Iq
a
> . 7. 3 fa
Send
�") 'E'd
cl-� a g -Pf

N.C. DIVISION OF_.WATER QUALITY
Water Quality Section
Complaint/Emergency Report Form
WILMINGTON REGIONAL OFFICE
Received 6y L401' .CL+y`l 1 )- /n^Date Q Z Time
Emergency Complainty City County C Q !y "'t bV s
Report Received From
Agency Phone No.
Complainant :n o rl,A1 O( 14 ; n s0"
Address 7303 S ; Ive it Spoon A4 W+L. 2A 4] L Phone No. 9 ! 6 45 -Z78
Check One: Fish KS Spffl Bypassy Animal NPDES N.D.
Storm"fer Weiland Other, Specify:
NatuNatureoers!
Refrv--%
-S+e�1 ck _ci not
lQD� tyI e��t_S-�,(@u
�'�-►__ ees v I �,415
km /f' �a
ire OkL4S SA\I S
, ' yj
F (7"r cer- n 4 11S AV,
c111 4u 11vwt.be.- Dri.
Time and Date Occurred On lo % —,I
Location of Area Affected C4.Ad Lf y%d icy cell �Q✓.�.
Surface Waters Impacted
Classification
Other Agencies Notified Y,,, J'o i- j li�%q-�rr Go•-� 5�1/q,� ��
Investigation Detal7s �►; eC t? - � r�.�-t a vl 'T Z- e �— • 7PJ ec, le A?C
SAWOSISHELLSWEPORT SHL
EPA Region IV [phone] Pesticides 733-3556 Emergency Management 733-3667 Wildlife Resources 733-7291
Solid and Hazardous Waste 733-2178 Marine Fisherfes 726-7021 Water Supply 733-2321 Coast Guard MSO 343-4881
127 Cardinal Drive Extension, Wilmington, N.C. 28405-3845 0 Telephone [phone] a Fax [phone]

[Fwd- OEC;tMar 12, 2002, Whiteville, NC 28472, hog operation Complaint]
Subject: [Fwd: OECA Mar 12, 2002, Whiteville, NC 28472, hog operation Complaint]
Date: Mon, 01 Apr 2002 13:22:22 -0500
From: Rick Shiver <[e-mail]>
To: [e-mail]
Hi, Stoney,
Please get up with John College and inspect this facility together.
Please make it a priority. Thanks, Rick
Subject: Re: OECA Mar 12, 2002, Whiteville, NC 28472, hog operation Complaint
Date: Mon, 01 Apr 2002 08:41:16 -0500
From: Coleen Sullins <[e-mail]>
Organization: NC DENR DWQ
To: Rick Shiver <[e-mail]>
CC: [e-mail], [e-mail],
Dennis Ramsey <[e-mail]>,
Steve Lewis <[e-mail]>
Rick -- would you please check into this for me. Thank you. Coleen
[e-mail] wrote:
> Coleen ... could you forward this to the appropriate person to look into
> it and to contact Mr. Hinson?
> Thanks, Doug
> ----- Forwarded by Doug Mundrick/R4/USEPA/US on 0312912002 02:54 PM
> www daemon
> <idaemon@earth2. To: Edmond
Burks/R4/USEPA/US@EPA
> epa.gov> cc:
> Subject: OECA Comment -Region 4
Tips and/or Complaints
> 0311212002 09:20
> AM
> The following is feedback from the OECA web site. You will NOT be able
> to reply to this message!
> Please use the following address (provided by the user) when responding
> to this message: [e-mail]
>
> Name : Donald Hinson
> Company :
> Reply via email to: [e-mail]
> Address : 2303 Silver Spoon Rd
> Whiteville,NC 28472
> Referring Page: http;,'/www.epa.gov/cgMlianc_e/complaints.html
> Subject :
> Message :
> Telephone Number : 9106482781
I of 2 4/1/2002 5-.08 PM

[Fwd. OECA Mar 12, 2002, Whiteville, NC 28472, hog operation Complaint]
> Alleged Violators Name : Carrolls Hog Farm
> Alleged Violators Address : 2682 Silver Spoon Rd
> Whiteville,NC 28472
> Tip/Complaint : This hog operation has ruined our standard of life. My
> wife"can't stand to go outside on the majority of days because of the
> stench. They are also located directly next to a stream that is so
> polluted from their runoff the water resembles what you'd expect to find
> in a septic tank.
> (optional) Field 1 :
> (optional) Field 2 :
> (optional) Field 3 :
> (optional) Field 4 :
> (optional) Field 5 :
> (optional) Field 6 :
Rick Shiver <Rick.Shiver( }a,ncmail.ner>
2 of 2 4/1/2002 5:08 PM

(Type of Visit Compliance Inspection C) Operation Review 0 Lagoon Evaluation I
Reason for Visit 0 Routine Ocomplaint • 0 Follow up 0 Emergency Notification 0 Other ❑ Denied Access
Facility Number 2 j Date of Visit:
Permitted 0 Certified 0 Conditionally Certified © Registered
Farm Name:
Owner Name:
Mailing Address:
4 Time:
Not O erational 0 Below Threshold
Date Last Operated or Above Threshold: C�
County: Ai t1^1 it S —
Phone No:
Facilit-
y Contact: 1 J Title: p Phone pNo:
Onsite Representative: &p(2r l A'ef7 /YiIli !1 ��F� iGi f�r115y� Integrator: Ca ro I 5
Certified Operator:
Location of Farm:
Operator Certification Number:
Swine ❑ Poultry ❑ Cattle ❑ Horse Latitude ' ' " Longitude ' ' "
= Design - ' Current
- Design Current i ..
Design Current ,
SPopulation-'-'-
Ca aci ;'
Nary Cal•:PouationCite
aiwine
ai Pulon "f`
❑ Wean to Feeder
`LI❑ Layer ❑ Dry
❑ Feeder to Finish
ILI Non -Dairy
❑ Farrow to Wean-
❑ Farrow to Feeder
❑ Other I I-
-,
❑ Farrow to Finish
Total Design Capacity .
❑ Gilts
< r
❑ Boars
- _ r -
Total SSL*
.
Number of Lagoons
❑Subsurface Drains Present ❑ Lagoon Area
ID Spray Field Area
]Holdmng Ponds / SolidTrap , e7, ❑ No Liquid Waste Management System
��
Discharges & Stream Impacts
1. Is any discharge observed from any part of the operation? ❑ Yes ❑ No
Discharge originated at: ❑ Lagoon ❑ Spray Field • ❑ Other
a. If discharge is observed, was the conveyance man-made? ❑ Yes ❑ No
b. If discharge is observed, did it reach Water of the State? (If yes, notify DWQ) ❑ Yes ❑ No
c. If discharge is observed, what is the estimated flow in gal/min?
d. Does discharge bypass a lagoon system? (If yes, notify DWQ) ❑ Yes ❑ No
2. Is there evidence of past discharge from any part of the operation? ❑ Yes ❑ No
3. Were there any adverse impacts or potential adverse impacts to the Waters of the State other than from a discharge? ❑ Yes ❑ No
Waste!Collection & Treatment
4. Is storage capacity (freeboard plus storm storage) less than adequate? ❑ Spillway ❑ Yes ❑ No
Structure 1 Structure 2 Structure 3 Structure 4 Structure 5 Structure 6
Identifier: 1
Freeboard (inches): 3 '7
05103101 Continued

Facility Number: z — f Q % Date of Inspection Z
5. Are there any immediate threats to the integrity of any of the structures observed? (ie/ trees, severe erosion,
❑ Yes
❑ No
seepage, etc.)
6. Are there structures on -site which are not properly addressed and/or managed through a waste management or
closure plan?
(If any of questions 4-6 was answered yes, and the situation poses an
El Yes
El No
immediate public health or environmental threat, notify DWQ)
7. Do any of the structures need maintenance/improvement?
❑ Yes
❑ No
8. Does any part of the waste management system other than waste structures require maintenance/improvement?
❑ Yes
❑ No
9. Do any stuctures lack adequate, gauged markers with required maximum and minimum liquid level
elevation markings?
❑ Yes
❑ No
Waste Application
10. Are there any buffers that need maintenance/improvement?
❑ Yes
❑ No
11. Is there evidence of over application? ❑ Excessive Ponding ❑ PAN ❑ Hydraulic Overload
❑ Yes
❑ No
12. Crop type
13. Do the receiving crops differ with those designated in the Certified Animal Waste Management Plan (CAWMP)?
❑ Yes
❑ No
14. a) Does the facility lack adequate acreage for land application?
❑ Yes
❑ No
b) Does the facility need a wettable acre determination?
❑ Yes
❑ No
c) This facility is pended for a wettable acre determination?
❑ Yes
❑ No
15- Does the receiving crop need improvement?
❑ Yes
❑ No
16. Is there a lack of adequate waste application equipment?
❑ Yes
❑ No
Required Records & Documents
17. Fail to have Certificate of Coverage & General Permit or other Permit readily available?
❑ Yes
❑ No
18. Does the facility fail to have all components of the Certified Animal Waste Management Plan readily available?
(ie/ WUP, checklists, design, maps, etc.)
❑ Yes
❑ No
-19. Does record keeping need improvement? (ie/ irrigation, freeboard, waste analysis & soil sample reports)
❑ Yes
❑ No
20. Is facility not in compliance with any applicable setback criteria in effect at the time of design?
❑ Yes
❑ No
21. Did the facility fail to have a actively certified operator in charge?
❑ Yes
❑ No
22. Fail to notify regional DWQ of emergency situations as required by General Permit?
(ie/ discharge, freeboard problems, over application)
❑ Yes
❑ No
23. Did Reviewer/Inspector fail to discuss review/inspection with on -site representative?
❑ Yes
JZINo
24. Does facility require a follow-up visit by same agency?
❑ Yes
❑ No
25, Were any additional problems noted which cause noncompliance of the Certified AWMP?
❑ Yes
❑ No
13 - No violations or deficiencies were noted during this visit. You will receive no further correspondence about this visit.
ti a referto queffielt
lai�E� S�a;Lorngll recommends ons�or aPAWer eomments.se
drawings.ofacili rezplainnsges as necessary): [] Field Copy ❑ Final Notes
kvSTen a!eA ;4-o ci' DA'i�ola;nk O-{' 5-�eytG '4rid f n f1 L1jed i4fe.,)A&
ce�:n9 From 'Arrt , —T referred -the .s4erv'17 C-0"ifla'i'I ,i v41E-I
1.,� �o Lv ►11 a l fQ�,v V� �n �t� Co--? k5 wec k s . w�c..ler I vq 1' + � —.r mr e.t o>�
p�'ejuee� were 4uJf� r"a� 41le Sareot✓�� LVh;GL1 iS aalyacenf�'
stew no ev � t��nce o¢ q d: sG ha✓' e of .Sw�Yte t��.s�e f��,ti.-file-F�rrK .
W;fl-Fo1�4wU Q�'' ✓k�f2 �U%f3 Alp IeCe) vQG� ,r7
A
Reviewer/Inspector Name S 1 W , JIWI[ ., I
Reviewer/Inspector Signature: Date: z D L
05/03/0I
Continued

A
FacilityNumber: Date of Inspection �- D
Odor Issues
26. Does the discharge pipe from the confinement building to the storage pond or lagoon fail to discharge at/or below
liquid level of lagoon or storage pond with no agitation?
27. Are there any dead animals not disposed of properly within 24 hours?
28. Is there any evidence of wind drift during land application? (i.e. residue on neighboring vegetation, asphalt,
roads, building structure, and/or public property)
29. Is the land application spray system intake not located near the liquid surface of the lagoon?
30. Were any major maintenance problems with the ventilation fan(s) noted? (i.e. broken fan belts, missing or
or broken fan blade(s), inoperable shutters, etc.)
31, Do the animals feed storage bins fail to have appropriate cover?
32. Do the flush tanks lack a submerged fill pipe or a permanent/temporary cover?
❑ Yes
❑ No
❑ Yes
❑ No
❑ Yes
❑ No
❑ Yes
❑ No
❑ Yes
❑ No
❑ Yes
❑ No
❑ Yes
❑ No
100 4en4" 01 'f--KFrke4 S o egg; -1A» i r-rR 1 s i h UP9 e rl d >eV1J Epp. �d vtef .
O5103101
_ .. _.... ..,
_

soRC
Uk
Yes
sz
Lp
z.,
•o
m�
-' UST
su
�
m
_ i
C
m
m�
Z
s��
-.
Woo I`�••
1

Cecil Barnhill, Owner
Six B Farm
Post -Office Box 92
IC"L r'LIM
Evergreeen, NC 28438
Dear Mr.Barnhill:
J
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF AIR QUALITY
May 8, 2002
Z4 - ! D 7
Subject: Air Quality Compliance Inspection
Six B Farm
2682 Silver Spoon Road
Evergreen, North Carolina
Columbus County
The subject hag farm was inspected on April 5, 2002, April 9, 2002, and April25, 2002,
in response to an' odor complaint. A copy of the new animal odor regulation (Section 1800 -
Control of Odors) was issued to you and discussed during -the inspections.
The farm was operating in- compliance with 2D _.1800 during the inspections: No
objectionable odors associated with the farm were -.observed beyond the >.boundary.of:the
animal operation_ The inspections revealedthat.the management pmcticeslisted in2D.3 802
(c) (1) through (5) have been implemented as.regdired.
It is my understanding that -the _wind• -conditions .and -time :of -;waste :application pare
.monitored at this .farm. - The management :practices :associated with pit flushing (discharge
practices) are -also monhored-and changes-addressedU-necessary.
This office will conductperiodic.odor.observations at.the;complainanVs'.home whenzn-
-inspector is in the community. You will benotified'immediately ifan-observation'indicates
that there is.an objectionable odor=associated.with-the farm.Ropefiilly,:theTmb1enixan''be _
:identified•and-eliminated-'if this_situation occurs.
:In view of the _above, :this office -is --requesting that you-review_additional,;preventative
=odormeasuresthat could:beimplemented:atthe_farm:'Triis officeiecomxii; i6 s:thatyoutreat
-the lagoonwithjj�icrobialproducts=andplantadditiona-l-vegetationbamers:uound thefarm:'
These measures, :if implemented, -should :have a positive effectt :on,public-Telatiansn
-additioujiPto reducing odors.
This office is also requestizig thatyouveriry.that.the wastewater.appheationspraycystem .
intake is located near the surface of the wastewaterlagoon.:Thisis necessarytoprevent the
irrigation system from -removing -the .wastewater . located:in:the,permanent treatmentzone of
-the lagoon. Vastewater-ftom the permanenttreatmentzone ds-higher n_solids.and odors.
WILMINGTON-REGIONAL OFFICE
'127.CAROINAL-DRIVE EXTENSION, WILMINGTON. NC'2a405
PHONE [phone] FAX (910) 350=2004 WWW.ENR'STATE_NC.USI`NR/
AN EQUAL OPPORTUNITY I AFFIRMATIVE ACTION EMPLOYER —.50% RECYCL£D110% POST CONSUMER PAPER

�z t� -•:s-. a^ _ �, .�ei+,y:s+,;-'""�.,- _;-�'�,y.-=r_-,:7-r_`� -"-�-'�--.'�'.-���:=ter-- ..F-.�_ � - �7'o'.'T�..haCYf
�•-: �.. ��i"�.'�-..�':� _ . �-^'-'-=��= --'-J...r-sue - _ _-:..wc���.. - _ r . � -. - - - - - - _- .- - .- -• . -. =- .
- NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND .NATURAL RESOURCES
DIVISION OF AIR QUALITY
Cecil Barnhill
May S, 2002
Page 2
The inspection could not have been completed without your cooperation and assistance.
Please contact me at work [[phone]] or at home f [phone]] if you have any
questions regarding this matter.
Sincerely,
Terry McCall
Environmental Technician V
Wilmington -Regional Office
cc: ,CF
_7ohn.C6llege
:StoneyMath3s
S
=Ga y'Saunders
-WIL•MINGTON REGIONAL OFFICE
127.CARDINAL DRIVE EXTENSION. WILMINGTON. NC 28405
PHONE [phone] FAX(910),350-2004.WWW.ENR.STATE.NC.USIENR/
- AN EQUAL OPPORTUNITY !AFFIRMATIVE ACTION EMPLOYER- 500%' RECYCLEDl10% POST CONSUMER PAPER

_ _ _ .. __• f'y.
iAl
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF AIR QUALITY
May 8, 2002
Donnad Hinson
2303 Silver Spoon Road
Whiteville, North Carolina 28472
Subject: Animal Odor Complaint
Six B Hog Farm
Columbus County .
Dear:Mr. Hinson:
The Wilmington Regional Office (WiRO) of the Division of Air Quality (DAQ) has
received and reviewed your -complaint regarding swine odors from an animal operation
located near your home.
The details of the new animal odor rule adopted by the state Fnvironmental
Management Commission were discussed with Mrs. Hinson at your Silver Spoon Road
home on April 9, 2002. Copies of the rule, brochures that provide additional details about
the rule, and objectionable odor'logbook forms were issued to Mrs. Hinson. The guideline
orprocedure.that DAQ follows in identifying objectionable odors was discussed with Mrs.
Hinson. The odor'intensity scale.(0 to 5) wnich'is part,of.the procedurewasexplained.
Your. complaint -was evaluated on April 5.2002, April 9, 2001, and April 25, 2002.
Odors with a variable intensity rating of 1(very.fWnt).to'3 (easily noticeable) were observed
downwind of the farm<on Silver. Spoon -Road during SSW -and -SW •winds. These'odors
were not classified or defined as objectionable under.the current.Air Quality .guidelines.
'No odors (O `intensity) were observed at your -'home during the evaluations.
-In.addition,:an inspection ofthe7suspect'farm '(Six`B-Farm),whiWis owned.by,Cedil
- - =Barnhill was conducted on -the above discussed observation (evaluation) dates. -Compliance
with 2D A 800, • Control ,of, Odors' was .being :achieved during the :inspection and -the
"_inanagement-practices Iisted in 2D .:1802 (c} :.(1.} :through (5)':havebeen implemented -.as
! ,required... -'Spraying practices ,were discussed :in .detail. The farm';indicated that -they
1 •. currently monitor the wind direction and time of waste application'in an.effortto.reduce the
!_ impact on homes=in.the_cormrn irdty. •The:f.illowing:recommendations were made:to'Mr.
Icy Barnhill as-a-result.of-the inspections: _
tom- •_ - .
..,a) Treatlhe=lagoon.with.amicrobial.product or.additive. Products ofthis-type:have '
the .,potential -:to reduce lagoon .sludge -which :improves odor :and other
environmental,parameters.associated with swine manure.management.
Plant vegetation around the, parameters of the farm especially -near the'lagoon and
.barns.Vegetation'barriem,serve,as.a-_wind-and odor break:and-can-also:absorb
odors. -
-WILMINGTON REGIONAL OFFICE
-127 CARDINAL DRIVE EXTENSION, WILMINGTON, NC'28405
PHONE [phone] FAX [phone] WWW.ENR.STATE.NC.US/ENRI
-AN EQUAL OPPORTUNITY 1AFFIRMATIVE ACTION EMPLOYER - 50% RECYCLEDl10% POST CONSUMER PAPER

77,
PS
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF AIR QUALITY
Donald Hinson
Page 2
c) Verify that the animal wastewater application spray system intake is located near
the surface of the wastewater lagoon. This is necessary to prevent the irrigation
system from removing the wastewater located in the permanent treatment zone of
the lagoon. Wastewater from the permanent treatment zone is higher in solids and .
odors.
d) ; Continue to monitor the wind direction and time of waste application in an effort
to reduce the impact on homes in the community. Continue to monitor the
management practices associated with pit flushing (discharge practices) and
institute changes if necessary.
The WiRO appreciates your continuing patience in this matter. This office has
received numerous complaints on approximately forty hog farms since the odor became
effective, and we are responding to these cases as fairly and quickly as practical. We will
continue to monitor your complaint through periodic odor observations and provide
assistance when possible.
The goal of the new rule is to control objectionable odors from, animal operations,
not to eliminate. all odors from these facilities. The ruledsa first step toward dealing with
such.problems. Hopefully, the rule will help reduce and ultimately. resolve such problems
:as -it -evolves.
Please:Feview the.accuracyofthe.enclosed map. The:tractor. on the map represents
the swine operations 'located'in:your'immediate community that were "listed'in .DAQ's
.DeLorme mapping :database. The :map .appears : to be _correct :based .on the information
-obtained duringApril,9, 2002:meeting with Mrs..Hinson;'however,'ifyou observe any errors
,please -.correct and:return.
:Additional odor'logs:have:been,enclosed:for,your.converiience. ,Please contact=me -
:at •work_[(910)'395=3900] or.athome:[(9.10)3.92-1022]:if you have:any-questionssegarding
this matter.
:Sincer0y,
Ca
Terry -McCall
=Environmental Technician-V
'Wilmington:Regional Office
.CC:.CF-- WiRO
L.Gary.Saunders
John College -- Stoney, Mathis.
WILMINGTON REGIONAL OFFICE
127 CARDINAL"DRIVE EXTENSION, WILMINGTON, NC 28405
PHONE [phone] FAX [phone] WWW.ENKSTAIE.NC.USIENR1
AN EQUAL OPPORTUNITY / AFFIRMATIVE ACTION EMPLOYER - 50% RECYCLED110%POST CONSUMER PAPER

- CO- - SS1519 SS 19 -cn SZTO55 F1�daS
- rn N n■---
Donald & Margaret Hinson Complaint
9-1-4
26'
Bav
Rough Horst Bay
24009//I Not identified as a suspect.
i 24a22
COW B1
N340 25.1 F - W780 51.04'
Complainant - Donald & Margaret Hinson
2303 Silver Spoon Road (SR 1103)
Whiteville, NC 28472
Columbus County
(910) 648 -2781
I P4 24'
774 l 9
240 Mag 14.W Wed May 08 14:08 2002
m
,m
(D 1997 DeLorme. Sveat Atlas USA n
Wyatts Cross Rt
24107
N340 25.02' - W780 50.39'
Suspect Farm - No. 24a107
Design - 4400 - Feeder to Finish
Intergrator - Browns of Carolina
Six B Farm
Cecil Barnhill, Owner
2682 Silver Spoon Road
SR 1103
Evergreen, NC
Columbus County
[phone]
Scale 1:31,250 (at center)
12000 Feet Local Road
r
SSRI 1531

v.
Agricultural Odoreomplilint
Date of Initial Complaint. 04/01/2002
Assigner! To:
Terry McCall
,Region: Wilmington
Collgiy ^'t
`. CnntplrrinruNs Nrrute (Lash:
Hinson
First:
Donald & Margaret
Phone: [phone]
ConrplainaiWv Off Street Address: 2303 Silver Spoon Road
Secondary 1003 Cily. Whiteville
ComplainaiWv Mailing Address: 2303 Silver Spoon Road City: Whiteville Zip. 284?2
This complaint turns initialy received via: O Telephone O Letter/Logbook Is the complainant keeping a log book(s)? ❑
Describe the nature of the odor(s): All activites associated with hog farming
List the firrnis identifled by the cotrtl)ltiinattt as poletttirrl problems: Six B Farm -No. 24a107- Cecil Barnhill, Owner
The odor affects the contplainant�s: home _ �. What year did the contplaitrant begin using this property:
flow often does the odor occur: anytime the wind is from the SE What is the worst time of day: no set pattern
Describe the worst weather conditions: anytime the wind is from the SE
The worst lime of year: no set pattern
Did the complainant voluntarily clai►n health affects: W Describe: There are concerns about the health effects of the odor on their children.
If So, please send a copy of this report to: Bill Pate, Environmental Epidemiology, Room 2A 272, Parker -Lincoln Building
Dirt the complainant mote any impacts on water: © Describe: The WOS has investigated and taken samples. No violations were documented
` Corntnents: The complaint was received through the WiRO WQ Section on 04/01102. It Is DAQ's understanding that the complaint originally came through EPA.
' p or and stream run-off pollution from a farm (24007) owned by Cecil Barnhill.
r
• The complaint addresses odor •..,.. .... _ _ ._.. .� •_
ti
t
1
Additional Recontemlations: Initiate investigation
Wed►iesdar, MaV 08, 2002
Page I of I
jlq
ref,

%
COF" ,01aihl HiStOry
Agricultural Odo'r Complaint -
rp
Date of Ittitial Cottiplain'l.- 04/01/2002 Assigned To: Terry McCall Region:. Wiim.ingtop County:
Coinplainatits Natne (I.ast):. Hinson First: Donald & Margaret P11011e.' (PIO)P4§72781
Contplaill (1111 'V 911 Street Address: 2303 Silver Spoon Road Secondary '1003 QJP: Whiteville
2303 Silver Spoon Road WhIteville Zip: 28472
Coin laimants Mailitig Aflilress: C�ify:
P
'';'Specific ConipittilitV history The rolloiving is a log of specific complaints registered by this complainant
N o, 2 a107- Cecil Barnhill, Owner
Weather
Tinie Duration' Auitual Streitgth Stispected Soarce(s) Six 8 Farm 4
Swine objectionable Spraying Lagoon: W Hotises W, Dr Litter: El Whid: SE
y . . .
:
Receive Vitt:• Other Source(s) See additional details for more information. Speed
Temp
11�t colliplait) wit's home Cotwitems: The complaint was received through the WiRO WO Section on 04/01/02, It is IDAQ's
understanding thatthe complaint originally came through EPA. The complaint addresses
odor and stream run-off pollution from a farm . (240107) own . ed by . Cecil Barnhill,
"Y
Date Time Duratiott Attittial Strength SuspectedSource(s) Six 13 Farm -No. 241107- Cecil Barnhill, Owner
Weather
(lirs) Swine objectionable Spraying Lagoon Hotises Dry Litter WindSE
Spged;
V Other Sotirce(s) See additional details ki more Information.
Received Via:
TqP'P
M1 CWw;1ahtaW!s home Cottittients: This complaint was received during a 04/08/02 meeting with the complainant (Mrs. Hinson)
at her home. The hog odor always Impacts her home on a SE wl6q jegiirdliss'of the
weather or the time of the year.
iVednesilalv, Jfiq 08, 2002
Ne I ?f 1

Investiption History Log
Agricultural_ Odor Complaint
Date of Initial Coinploil:it: 04101/2002 Assigned To: Terry McCall Region. Wilmington coycity;'
Complainants Nriiiie (L(tst): Hinson First: Donald & Margaret Phalle:' (91Q) 64Q-2781
Camplaiva►it's 911 Street Address: 2303 Silver Spoon Road Secondary i0t}3 City: Whiteville
Conipkiinri►rt's Mailing Address: 2303 Silver Spoon Road _ City: Whlteville Zip; 28472
hivestigatio►i History
The following is a log of investigations concerning this complainant
04/25/2002 10:00:00 AM
2 hrs Cool and raining. No Odor was observed at the
❑
complainant's home but an odor with an intensity that
varied from 2 to 3 (faint to easily noticeable) was
observed at arrival and an odor with an intensity that
varied from 1 to 2 (very faint to.faint) was observed at
departure downwind of the Six t3 Farrp (Ho. 24007j
on Silver Spoon Road.
04/09/2002 8:00:00 AM
2 hrs Q Warm and PC with a SW wind. No odor was
❑
observed at the complainant's home but an odor with
an Intensity that varied form 1 to 2 (very faint to taint)
was observed downwind of the Six B Farm (No.
24a107) on Silver Spoon (toad. .
04/05/2002 9:30:00 AM
2 hrs Warm and clear with a SSW wind. No odor was
❑
observed at the complainant's home but an odor with
an intensity that varied from 2 to 3 (faint to easily
noticeable) was Observed downwind of the Six'S Farm
(No, 24alp7) on Silver Spoon Road. Inspected
suspect fait and with the owner -and John College Of
DAQ.
Alto, 08, 2002
_
.5
; : rage 1 of l

WATFTo
v� r
1
O `C
April 8, 2002
Donald Hinson -
2303 Silver Spoon Road
Whiteville, NC 28472
Subject: Complaint Inspection
Six B Farm
Owner Cecil Barnhill
Facility Number: 24-107
Columbus County
Dear Mr. Hinson:
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Gregory J. Thorpe, Ph.D., Acting Director
Division of Water Quality
I inspected the referenced facility on April 2, 2002 in response to your complaint which I received on
April 1, 2002. In your complaint, you indicated that there is a stench from the farm; I referred this
complaint to the Division of Air Quality to Terry McCall who can be reached at the number below. You
also indicated that the farm is located next to a stream which is polluted from farm runoff and the water
in the stream resembles that of a septic tank. During my inspection, I did not see evidence of any runoff
of swine waste from the facility into the stream. I took samples from the referenced stream during my
inspection. The sample results did not conclusively show that the farm is impacting the surface waters at
that time. The water in the stream was tannic in appearance which is a natural occurrence in some
waters. If you have any questions concerning these matters, please do not hesitate to contact me at 910-
395-3900 ext. 203.
Sincerely,
Stonewall Mathis
Environmental Engineer I
cc: John College, DSWC-WiRO
iltniti on= .iles24I0_ 7
Wilmington Regional Office
127 Cardinal Drive Extension Phone: [phone]
Wilmington, NC 28405-3845 Fax: [phone]

CONSULTING
CHEMISTS
Customer:
NCDENR-DWQ
127 N. Cardinal Drive Ext.
Wilmington, NC 28405
Attn: Stonewall Mathis
Date Sampled:
Sampled By:
WATER:
Environmental Chemists, Inc.
6602 Windmill Way - Wilmington, North Carolina 28405
[phone] (Lab) - [phone] (Fax)
[e-mail]
NCDENR: DWQ CERTIFICATE #94, DLS CERTIFICATE #37729
REPORT OF ANALYSIS
04/02/02
Stonewall Mathis
Date of Report: April 4, 2002
Purchase Order #:
Report Number: 2-1664
Report To: Stonewall Mathis
Project:
24-107
24-107
24-107
Sample ID
1
2
3
# 3779
# 3780
# 3781
Fecal Coliform, colonies/100 mL
220
81
210
Comments:
Reviewed by: Irr..

ENVIRONMENTAL CHEMISTS, INC
Sample Collection and Chain of Custody
• n : C� �N �� �J Q + Q C� NCDNRtDWQ Certlecata #94, DLS Ca�rsh 03MO
Collected By: 044+2,`5
6602 Windmill Way
Wilmington, NC 28405
Phone: [phone]
Far: [phone]
S m 1 TYpeof I= Influent
E=Effluent n Mwelig
= 3trea bu."50HO
SLR muciae Other:
Sample Idendf cation
Collection
°'
GQ
I G
w
I
�
PRESERVATION
ANALYSIS REQUESTED
d
0
o
DATE
TIME
TEMP
2-q -10 7
,57
c
3'7'j
v
�e6'� 1
G
2-q-107 2
s
c
3?
G7
2y - ie 7 3
5-7
c
re C'..
M
G
C
P
G
G
C
P
G
G
C
P
G
G
C
P
G
G
C
P
G
G
C
P
G
G
C
P
G
G
NOTICE — DECHLORINATION : Samples for Ammonia, TKN, Cyanide, Phenol, and Bacteria must be dechlorinated
0.2 ppm or less in the field at the time of collection. See reverse side for instructions,
Transfer
Relinquished By:
Date/Time
Received By:
Date/Time
1.
2.
Temperature when Received: /. p Accepted: / ej d: example Requested:
Delivered By: Received By: Date: Z Time: .� ► �5
5
Comments:
7

UMPORTANT NOTICE
North Carolina Division of Water Quality (NCDWQ) is strictly enforcing EPA regulations for sample collection and
preservation
Client Must Provide the Following Information
SAMPLE IDENTTFICATION (Container Associated with requested testing)
2. SAMPLE TYPE (Composite, Grab, Water, Soil, etc.)
3. DATE COLLECTED
4. Mffi COLLECTED
5. SAMPLE COLLECTOR
6. PRESERVATION (including Temperature and pH)
Temperature: Samples MUST be refrigerated or received on ice between 2 and 6 o C. Samples received
within: two (2) hours of collection must show a downward trend. Therefore, please record temperature at
collection in space provided on collection sheet.
pH: A two (2) hour limit to chemically preserve samples by pH adjustment is allowed, except for metals
samples reported to the Groundwater Section which must be acidified at the time of collection.
Caution
These sample bottles may contain small amounts of acid or other corrosive and potentially harmful'
chemicals. Laboratories are required to add these chemicals for certain analyses in order to comply
with EPA preservation requirements. Use extreme care when opening and handling the bottles. If
any chemical should get on your skin or clothes flush liberally with water and seek medical attention.
DECHLORINATION INSTRUCTIONS
CAUTION: DO NOT Mix tbiosulfate with acid in bottle before collecting samples as a
violent reaction will occur.
Dechlorinat ng_Samules that Rouire Acid Preservation
I. Add 4-5 granules of thiosulfate to a bottle with no acid preservative (unpreserved BODII'SS bottle).
2. After rpixing to dissolve the thiosulfate, pour half of the sample into a bottle containing acid as a '-
prwervative (Ammoniarl'KN). ,
3. Then completely fill both bottles with fresh sample.
The Laboratory will verify and document the above requested information.
ref. NCAC 2H.0805 [a) ('n (lull.
"At any time a laboratory receives samples which do not meet sample collection, holding time, or preservation
requirements, the laboratory must notify the sample: collector or client and secure another sample if possible. If another
sample cannot be secured, the original sample may be analyzed, but the results reported must be qualified with the nature
of the kfitction(s). And the laboratory must notify the State Laboratory about the infiaction(s). The natification must
include a statement indicating corrective actions taken to prevent the problem for fiuttim samples.
of NCAC 2h 0805 (a) 0 sN�."

Re: Hog Operation Complaint from OECA 3/12/02 Whiteville,NC Z 4 - f Q7
Subject: Re: Hog Operation Complaint from OECA 3/12/02 Whiteville,NC
Date: Mon, 08 Apr 2002 15:37:03 -0400
From: Coleen Sullins <[e-mail]>
Organization: NC DENR DWQ
To: Stonewall Mathis <[e-mail]>
Thanks Stoney. Coleen
Stonewall Mathis wrote:
> Coleen,
>
> I inspected the Six B Farm belonging to Cecil Barnhill, Facility
> #24-107, on April 2, 2002 in response to the referenced complaint.
> Please find attached a letter that I am sending to the complainant
> today. It describes my findings at the farm. Please contact me if you
> have any questions.
> Stoney
> -------------------------------------------------------------------------
> Name: 24-107complaint.doc
> 24-107complaint.doc Type: Microsoft Word Document
(application/msword)
>. Encoding: base64
> Download Status: Not downloaded with message
1 of 1 All 1/2002 1:34 PM

N.C. DIVISION OF,. __WATER QUALITY
Water Quality Section
Complaint/Emergency Report Form
WILMINGTON REGIONAL OFFICE
Received by .a�d�«`� T It 1� S Date l Z- rime
Emergency Complainty City County Cd 1 " °1,
Report Received
Agency Phone No.
Complainant rj A 2 i ; n 50"
� 30 3 S', Ivey f- o !.✓�;-�� � ��� NG-(4b -278I
Address A a� iz� zg 0 ILPhoneNo. _ _ - -
Check One: Fish Kr71 Spill Bypassy Animal NPDES N.D.
Stormwater Wetland Other, Specify:
Nature of Referral
C• Zt 'k nd
�a) ? V4 Cry , c f"eei r- , re r V I �; n L0 ^1
cevV-,
; Y%'LpAG4SSc,tis
ipI., ►n �' n�':
CeG;1 L�a�n��11s ��„,&A-%
f ctc; 11�} 4 `} , 1,, e 2-4 - l01]
Tune and Date Occurred ano o, ") - -
Location of Area Affected �rea of'r,,t..��ry�1'o�}� Ol►rC�Ga O t ���C.¢���✓�
Surface Waters Impacted Classification
Other Agencies Noi ied ✓�"►' S }<et.,, SO:_ � :j IV44f Coo!^ .5qV- 4
Investigation Detal7s S eC ,[ �� �^rh 0 'T �- d 2— • Ea_ Se
Investigator
3/a Z_
SAWOUSHELLSIREPORT SHL
EPA Region rV [phone] Pesticides 733-3556 Emergency Management 733-3867 Wildlife Resources 733-7291
Solid and Hazardous Waste 733-2170 Marine Fisheries 726-7021 Water Supply 7334321 Coast Guard MSO 343-4881
127 Cardinal Drive Extension, Wilmington, N.C. 28405-3845 0 Telephone [phone] • Fax [phone]

1Fwd: OECA Mar 12, 2002, Whiteville, NC 28472, hog operation Complaint]
Subject: [Fwd: OECA Mar 12, 2002, Whiteville, NC 28472, hog operation Complaint]
Date: Mon, 01 Apr 2002 13:22:22 -0500
From: Rick Shiver <[e-mail]>
To: [e-mail] .
Hi, Stoney,
Please get up with John College and inspect this facility together.
Please make it a priority. Thanks,.Rick
Subject: Re: OECA Mar 12, 2002, Whiteville, NC 28472, hog operation Complaint
Date: Mon, 01 Apr 2002 08:41:16 -0500
From: Coleen Sullins <[e-mail]>
Organization: NC DENR DWQ
To: Rick Shiver <[e-mail]>
CC: [e-mail], [e-mail],
Dennis Ramsey <[e-mail]>,
Steve Lewis <[e-mail]>
Rick - would you please check into this for me. Thank you. Coleen
[e-mail] wrote:
> Coleen... could you forward this to the appropriate person to look into
> it and to contact Mr. Hinson?
> Thanks, Doug
> ----- Forwarded by Doug Mundrick/R4/USEPA/US on 0312912002 02:54 PM
> -----
>
> www daemon
> <idaemon@earth2. To: Edmond
Burks/R4/USEPA/US@EPA
> epa.gov> cc:
> Subject: OECA Comment -Region 4
Tips and/or Complaints
> 0311212002 09:20
> AM
>
> The following is feedback from the QECA web site. You will NOT be able
> to reply to this message!
> Please use the following address (provided by the user) when responding
> to this message: [e-mail]
> Name : Donald Hinson
> Company :
> Reply via email to: [e-mail]
> Address : 2303 Silver Spoon Rd
> Whiteville,NC 28472
Referring Page: http:,-'Iwww.epa.gov/compliance/coLnplaints.html
> Subject .
> Message :
> Telephone Number : 9106462781
I oft aIMMI ;.nR PKA

[Fwd: OECA Mar 12, 2002, Whiteville, NC 28472, hog operation Complaint]
> Alleged Violators Name : Carrolls Hog Farm
> Alleged Violators Address : 2682 Silver Spoon Rd
> Whiteville,NC 28472
> Tip/Complaint : This hog operation has ruined our standard of life. My
> wife can't stand to go outside on the majority of days because of the
> stench. They are also located directly next to a stream that is so
> polIuted from their runoff the water resembles what you'd expect to find
> in a septic tank.
> (optional) Field 1 :
> (optional) Field 2 :
> (optional) Field 3 :
> (optional) Field 4 :
> (optional) Field 5 :
> (optional) Field 6 :
Rick Shiver <Rick.Shiverncmail.ner>
2 of 2
4/1/2002 5:08 PM

�i �, v.l
I 5 .,,j
?
'•�
,.4 C J� i°w�q w
l r' 1
r� J•
�i \
1 s •+� \` J
.. rl -o' rr.J
S..
•ro 'l6z
�lp�j
�S,,�h1 Sr�J•YEr,4
�?- k L'i�;�.�',%,:'"/
r.
t
..
4A11 i
i7'•a I��p 3Ly4411
.I' fir\ .,1 ii
- ' F
d �
� f +
�/) �+ l Tw,J"^i•st'
-t.'
14r
f•:jt'}•:
}Trr /ram ♦ :'N
\
}' 'f
• t i; -
`�.,�
r-P`.,;`�\
°
1'...
+ r 4
-_ 1 .�- v ?
2,; -+`r ..
� I l i 1 j"iyJT 1•'
3''
h i��; }97_r /yj:
�1 r ,/�'
1 .i 'Iirl�S
; a�+
rl• + r ��� ^'7
I S `
++=
;-rr "i:"/ ? r' f ,
4 -Y .:;L
:.i't `.,i.1f+
n'% '#5 4,•3
� r �Je '�'
�'
k i
��.
'l�rl• :.' . 3I4A' .., ,;
4.: a• -�
I,�k;'I . 1 [3,.
[ j ;1�
'gi i r
++,,II -'1.::
fit•:.'• ir(. ;'•�w } 7.
I.
/•
:i',.,f
'/'.: .L:
i .,� nn J
��
�•'r '•'� .. ovr. so.
f •,Ilt .,.�ri+�.
'.;
['r�1y ��V
X.Yr.� S I.
r�,
fi- �' T S4}S IJt tad
Ty(S.
a-
�l,.�J
�gr+� � ,/t
, 4?
1
al•.'., .°
J:?.
,:i
`f to
� �.
-n �11;,.. r:,..�:`r
�
;r dl; •u1• s:s
',
ti',ti
, ('�
�� `/
i._�,l
/,,
)• kilt,'t
�+ '
'
n{
.i'r'
ra
{Y
.1 ) '
�
/.t. (
/��•�+:
1rt a1},
pe J' 1-°a %r j1
,,
,,
/ ;'F�'
,�
•I ♦yf
,�� `. ;.I'IEr : �
/�'r-rr
:,•'rip t r
� � !�1,'.�' 4 �'
'
_
..
t .:,�';
ry�,:4
. t r ,fWl, ,Y'S` r
1(R#
1:. A?•i: T
y i ,
'..f" o'
'71'
f 'r 5 r i 1 �ug. -y
1'+•-.i
r -
X r Alh
J,• ,f`�r�a.�, j' 1'•
I.
S. �',
s i-•4rin, i,
„V.p� y �p ,.
J �F'9 +t i x, i
r , ,�6 �r H [,� S'�t
5
:l • '�;J �1� ii f�U
P t.; 4 [/a
`i•?'/ mot' r�
�Y� 4.
Il t I
o u'' +%r v�/
w rp
-.:�^`
f r F, r�+t /
f it,
I,L -.I'sr // r
r �, 1 �'•r'I LVVfIII
;r;` riM1 �I
i }. y 1Cn SF.��
,. i
�� /a, - 11
-�I,
:�'1 51R -
.1�• \�9 1}
�,
�4t ,J , r.. I ['+�.
^� f5 -j I,k�
I f.
,
°'{•
}
1,
JaJ dl 1
I.. �_
'r r'i�
'x
�'-,
v,i: i '•a
}'
o -I i.,, I t I
.lril
./ ;i•.: :.
Fc' t r+' a
�1
I. 1) �i"/:
+' �f f :7
r .
'i>y;''"r`..
•
r,, a:�.,, '.ii
n
o
:;.
.� .•i -
'�1::
•1 f'S
., ' '
•''LY.
: 1 :It?+' .''Rii'r++
:. t'..(;141'•.4' f
i Sr:
t.�••
t
,� )f'
+
V.
ee'�' 't .c
r+rt�-�,yT�;, t•S
j
ti i '
� V +� ,{.'?r I
r.�eJ i
I ®
,..
K.J'♦
7 r
y�t..�
.
5•r.�
WHO., ` Y :,•, 1,'
.L!�'\ �I' ills `rl
;.
I
I �r/�
gX 1i Mir
�1�.•
I !, r �
`
r1'
� !,
1,• �-
'. rr y'_ L :3 t'f( ��
°,..
O rk
..
1 rl
I,,
s v•
�•.'r
{I,, t`�l,J, t
e.. �. i
44 S 1 i�' I iir
- Q
_
4.
ti{Lr.
-r.y�,d-L,S.
low
-
7 �!I" `'
ri. f--
1 4
- l .(1 •Jib'
�,la1
° rA
AT
OV33YDH3A3
IN33HUH /i3/
w MNAlZ Z5
w
. i.; re ,,ski'$ rh1 r ' • , . /
19
c� jrj 1�
N
�hb
�''�'j 11 bi: .ram :s
M
u

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
Michael F. Easley, Governor
William G. Ross, Jr., Secretary
Kerr T. Stevens, Director
RICHARD D. BARNES
BARNES FARMS INC.
3965 KINGS CROSS RD
LUMBERTON NC 28358
Dear Richard D_ Barnes:
JUN 2 L001
CDENR
NORTH CAROLINA DEPARTMENT OF
NVIRONMENT AND NATURAL RESOURCES
June 7, 2001
Subject: Application No. AWS240107
Additional Information Request
Barnes Farms Inc.
Animal Waste Operation
Columbus County
The Non -Discharge Permitting Unit has completed a preliminary review of the subject application. Additional information is
required before we can continue our review. Please address the following by July 7, 2001:
Please provide an updated Waste Utilization Plan (V4'UP). The 2/95 WUP is not based on the irrigation
desisn received on 3/10/99. Please note that this information has been requested since May 12, 2000. If
the information cannot be provided by July 7, 2001 the permit application will be returned as
incomplete and the facility will then be considered as operating without a permit.
Please note that all WUP revisions must be signed and dated by both the owner and the technical specialist. Please
reference the subject permit application number when providing the requested information. All information should be signed,
sealed, and submitted in duplicate to my attention at the address below. The information requested by this letter, must be
submitted on or before July 7, 2001 or the Division will return your application as incomplete in accordance with 15A
N.C.A.C. 2H .0200 and your facility will be considered to be operating without a permit.
Please be advised that operation of the subject animal waste management system without a valid permit is a violation of North
Carolina General Statute 143-215.1 and will subject you to the enforcement authority of the Environmental Management
Commission.
If you have any questions regarding this request, please call me at [phone], extension 544.
Sincerely,
E
Stephanie Milam
Environmental Engineer
Non -Discharge Permitting Unit
cc: Wilmington Regional'Office, Watti Quality
Columbus Sail & Water Conservation District
Permit File
1617 Mail Service Center, Raleigh NC 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
Michael F. Easiey, Governor
William G. Ross, Jr., Secretary
Gregory J. Thorpe, Ph.D., Acting Director
October 30, 2001
CECIL BARNHILL
SIX B FARM
P O BOX 92
EVERGREEN, NC 28438
4 �
llllFAX
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Application No. AWS240107
Additional Information Request
Six B Farm
Animal Waste Operation
Columbus County
Dear Mr. Barnhill:
Thank you for your Notification of Change of Ownership form, we received on October-22,
2001. Hopefully you are aware that the previous owner of your farm, Mr. Ricky Barnes was working
with Ms. Stephanie Warn to complete his General Permit application. Ms. Milam has since left our
unit, therefore the responsibility of finishing your project has been given to me.
I have gone over Mr. Barnes' submissions and past reviewer comments, since 1998, and in light
of your change of ownership notification, need only the following two items completed to finish the
permitting process. Please address the following by November 30, 2001:
1. Please sign the Nutrient Management Plan dated July 12, 2001, as the OWNER. Keep the
oric,M4 make two copies to send back to us.
2. Please review and sign and date the enclosed "Required Specifications" Keep one copy
with your Nutrient Management Plan, and send two copies back.
3. Send one more additional copy of the materials enclosed with Ms. Sonya J. Barbour's letter
dated July 13, 2001. Only one copy was sent to our office, and we need another copy for
the Wilmington Water Quality Regional Office to keep.
Please reference the subject permit application number when providing the requested information. All
information should be signed, sealed, and submitted in DUPLICATE to my attention at the address,
below: '
NCDENR-Non Discharge Permitting Unit (attn: Theresa Nartea)
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
1617 Mail Service Center, Raleigh NC 27699-1617 Telephone [phone] FAX [phone]
\ An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper
http://h2o.enr.state.nc.us/ndpu/

Application No. 24-0107
Barnes Farms Inc.
Page 2
The information requested by this letter, must be submitted on or before November 30, 2001 or the
Division will return your application as incomplete in accordance with 15A N.C.A.C. 2H .0200 and your
facility will be considered to be operating without -a permit.
Please be advised that operation of the subject animal waste management system without a valid permit
is a violation of North Carolina General Statute 143-215.1 and will subject you to the enforcement
authority of the Environmental Management Commission.
If you have any questions regarding this request, please call me at [phone], extension 375.
Sincerely,
Threresa Nartea
Soil Scientist
Non -Discharge Permitting Unit
cc -Wilmington Regional"Office,, Water Quality
Harvest Net, Inc., Agri -Management Services, P O Box 32, Council, NC 28434
Permit File

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
OCT 2 5 2001
Michael F. Easley, Governor
William G. Ross, Jr., Secretary
Gregory J. Thorpe, Ph.D., Acting Director
RICHARD D. BARNES, CECIL BARNHILL
BARNES FARMS INC.
3965 KINGS CROSS RD
LUNBERTON NC 28358
Dear Mr. Barnes and Mr. Barnhill:
October 15. 2001
ACDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Application No. AWS240107"
Additional Information Request
Barnes Farms Inc.
Animal Waste Operation
Columbus County
Thank you for your additional information response received by the Division on July 17, 2001.
One of the last reviewers_ Ms. Stephanie Milam has since left our unit, therefore the responsibility of
finishing your project has been given to me. I have gone over your submissions and past reviewer
comments. since 1998, and have only found the following two items are needed to complete the
permitting process. Please address the following by November 15. 2001:
1. Please have your manager, Cecil Barnhill sign the Nutrient Management Plan dated July
12. 2001. Keep the original, make two copies to send back to us.4
?. Please.revievx-- and sign and date the enclosed "Required Specifications" Both you and
Mr. Barnhill, will need to do this. Keep one copy with your Nutrient Management Plan,
and send two copies back.
3. Send one more additional copy of the materials enclosed with Ms. Sonya J. Barbour's
letter dated July 13, 2001. Only one copy was sent to our office, and we need another
copy to send to the Wilmington Regional Office to keep.
Please reference the subject permit application number when providing the requested information. All
information should be signed, sealed, and submitted in DUPLICATE to my attention at the address,
below:
NCDENR-Non Discharge Permitting Unit (ann-- Theresa Nartea)
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
1617 Mail Service Center, Raleigh NC 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper
http://h2o.enr.state.nc.us/ndpu/

Application No. 24-0107
Barnes Farms Inc.
Page 2
The information requested by this letter, must be submitted on or before'Novernber 14, 2001 or the
Division will return your application as incomplete in accordance with 15A N.C.A_C. 2H .0200 and your
facility will be considered to be operating without a permit.
Please be advised that operation of the subject animal waste management system without a valid -permit
is a violation of North Carolina General Statute 143-215.1 and will subject you to the enforcement
authority of the Environmental Management Commission.
If you have any questions regarding this request, please call me at [phone], extension 375.
Sincerely,
/hrer�esa Nartea
Soil Scientist
Non -Discharge Permitting Unit
cc: Wilmington-Regional--Office,—Water Quality-)
Harvest Net, Inc., Agri -Management Services, P O Box 32, Council, NC 28434
Permit File

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
Ricky Barnes
Barnes Farms Inc.
3965 Kings Cross Rd
Lumberton NC 28358
DearRicky Barnes:
A iffl'?WA
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND N.4URAL RESOURCES
December 30, 1999
Subject: Fertilizer Application Recordkeeping
Animal Waste Management System
Facility Number 24-107
Columbus County
This letter is being sent to clarify the recordkeeping requirement for Plant Available Nitrogen (PAN)
application on fields that are part of your Certified Animal Waste Management Plan.
In order to show that the agronomic loading rates for the crops being grown are not being exceeded, you
must keep records of all sources of nitrogen that are being added to these sites. This would include nitrogen
from all types of animal waste as well as municipal and industrial sludges/residuals, and commercial fertilizers.
Beginning January 1, 2000, all nitrogen sources applied to land receiving animal waste are required to
be kept on the appropriate recordkeeping forms (i.e. IRR1, IRR2, DRY1, DRY2, DRY3, SLUR1, SLUR2,
SLD1, and SLD2) and maintained in the facility records for review. The Division of Water Quality (DWQ)
compliance inspectors and Division of Soil and Water operation reviewers will review all recordkeeping during
routine inspections. Facilities not documenting all sources of nitrogen application will be subject to an
appropriate enforcement action.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Ms. Sonya Avant of the
DWQ staff at [phone] ext. 571.
Sincere
r
Kerr T. Stevens, Director
Division of Water Quality
cc: Wilmington Regional Office
Columbus County Soil and Water Conservation District
Facility File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

State of North Carolina
Department of Environment
and Natural Resources IT 0 •
Division of Water Quality
RECEIVED
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary FEB 0 5 1999
A. Preston Howard, Jr., P.E., Direc or NCDENR
ENVIRONMENT AND NATURAL RESOURCES
February 4, 1999
CERTIFIED MAIL
RETURN RECYIPT REQUESTED
Barnes Farms Inc.
3965 Kings Cross Rd
Lumberton NC 28358
Attn: Richard D. Barnes
Subject: Application No. AWS240107
Additional Information Request_
Barnes Farms Inc.
Animal Waste Operation
Columbus County
Dear Richard D. Barnes:
The Non -Discharge Permitting Unit has completed a preliminary engineering review of the subject application. Additional
information is required before we can continue our review. Please address the following by March 6, 1999:
1.Please provide an irrigation design for this facility.
Please note that all WUP revisions must be signed and dated by both the owner and the technical specialist. Please
reference the subject permit application number when providing the requested information. All information should be
signed, sealed, and submitted in duplicate to my attention at the address below. The information requested by this letter
must be submitted on or before March 6, 1999 or the Division will return your application as incomplete in accordance with
15A N.C.A.C. 2H .0200 and your facility will be considered to be operating without a permit.
Please be advised that operation of the subject animal waste management system without a valid permit is a violation of
North Carolina General Statute 143-215.1 and will subject you to the enforcement authority of the Environmental
Management Commission.
If you have any questions regarding this request, please call me at [phone], extension 364.
cc: Wilmington.Regional-Office,-Water Quality
Permit File
P.O. Box 29535, Raleigh, North Carolina 27626-0535
An Equal Opportunity Affirmative Action Employer
Sincerely,
Dianne Thomas
Soil Scientist
Non -Discharge Permitting Unit
Telephone [phone] FAX [phone]
50% recycled/ 10% post -consumer paper

State of North Carolina
Department of Environmen t :
.�..> �.•_ •dam .%..s �:c.�.,.'l'
and Natural Resources
Division of Water QualifySEP 2 "
James B. Hunt, Jr., Governor:
Wayne McDevitt, Secretary
L3 Y— --
A- Preston Howard, Jr., P.E., Director
September 14, 1998
Richard D. Barnes
Barnes Farms Inc.
3965 Kings Cross Rd
Lumberton NC 28358
i • •
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Application No. 24-0107
Additional Information Request
Barnes Farms Inc.
Animal Waste Operation
Columbus County
Dear Richard D. Barnes:
The Non -Discharge Permitting Unit has completed a preliminary engineering review of the
subject application. Additional information is required before we can continue our review. Please
address the following components by October 14, 1998:
1) Per the Sixth Guidance Memo for Technical Specialists dated August- 18, 1997, the
allowable nitrogen application rate for any small grain overseed is 50 pounds per acre
above the normal application rate. Table 1 of your Waste Utilization Plan (WUP) states
that 133 pounds of nitrogen per acre is being applied. Please provide documentation to
show that these levels are acceptable or revise Table 1 to conform to the allowable levels at
the time (50 lbs/acre).
2) Your Mortality Management checklist was missing from your permit application. Please
provide this checklist for review.
3) The site map submitted with your permit application was difficult to read. Please provide a
new site map with the locations and acreages of the Fields listed in the WUP.
4) Your Animal Waste Management Plan Certification dated January 1, 1997 states that your
Facility is a "New, expanded, or existing facility without existing waste application
equipment for land spreading not using spray irrigation" (refer to Section H, Part D). Since
no existing waste application system exists, and the certification was dated after October 1,
1996, an Irrigation Design must be submitted with the permit application for review, per
NRCS requirements.
5) The WUP submitted with the permit application was signed and dated on February 3, 1995.
This differs from the start date of the facility which was on January 1, 1997. Please explain
this discrepancy in the narrative of operations.
6) The'following information was missing from your permit application. Please provide this
information for review.
a. Twenty-three (23) NRCS Required Specifications. Twenty (20)
Required Specs were submitted but 23 is required.
b. Irrigation Parameters
P.O. Box 29535, Raleigh, North Carolina 2762&0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Application No. 24-0107
Richard D. Barnes
Page 2
All revisions / amendments are required to be signed and dated by both the landowner and the
Technical Specialist before they are submitted for review. Please reference the subject permit
application number when providing the requested information. All information should be signed,
sealed, and submitted in duplicate to my attention at the address below. The information requested by
this letter must be submitted on or before October 14, 1998 or the Division will return your application
as incomplete in accordance with 15A N.C.A.C. 2H .0200 and your facility will be considered to be
operating without a permit_
Please be advised that operation of the subject animal waste management system without a valid
permit is a violation of North Carolina General Statute 143-215.1 and will subject you to the
enforcement authority of the Environmental Management Commission.
If you have any questions regarding this request, please call me at [phone], extension
MZ!
Sincerely,
Brian E. Mondschein
Environmental Technician
Non -Discharge Permitting Unit
cc: Wilmington Regional Office, Water Quality
Permit File

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
June 23, 1998
CERTIFIED MAIL
WE-TURNRECE PT REQUESTED
Ricky Bames
Barnes Farms Inc.
3965 Kings Cross Rd
Lumberton NC 28358
Farm Number: 24 - 107
Dear Ricky Barnes:
A ifflZ05%
NCDENR
NORTH CAROLMA DEPARTMENT OF
ENVIRONMENT AND MauPAL RESOURCES
You are hereby notified that Barnes Farms Inc., in accordance with G.S. 143-215.10C, must
apply for coverage under an Animal Waste Operation General Permit. Upon receipt of this letter, your
farm has sixty 60 days to submit the attached application and all supporting documentation. In
accordance with Chapter 626 of 1995 Session Laws (Regular Session 1996), Section 19(c)(2), any
owner or operator who fails to submit an application by the date specified by the Department
SHALL NOT OPERATE the animal waste system after the specified date. Your application must
be returned within sixty (60) days of receipt of this letter. Failure to submit the application as required
may also subject your facility to a civil penalty and other enforcement actions for each day the facility is
operated following the due date of the application.
The attached application has been partially completed using information listed in your Animal
Waste Management Plan Certification Form. If any of the general or operation information listed is
incorrect please make corrections as noted on the application before returning the application package.
The signed original application, one copy of the signed application, two copies of a general location
map, and two copies of the Certified Animal Waste Management Plan must be returned to complete the
application package. The completed package should be sent to the following address:
North Carolina Division of Water Quality
Water Quality Section
Non -Discharge Permitting Unit
Post Office Box 29535
Raleigh, NC 27626-0535
If you have any questions concerning this letter, please call at [phone] extension or Dave
Holsinger with the Wilmington Regional Office at [phone].
Sincerely,
A. Preston Howard, Jr., P.E.
cc: Permit File (w/o encl.)
Wilmington Regional Office (w/o encl.)
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recydedl 10% post -consumer paper

ea
Er
Ir 'p
a D
nj •C a
cc d
Q V Qm
U L U
� 0
E
1d �% [
SQZ
L
1�
o
m
�
10
yF
f� N
m
m
I
o
a
E
a
m
rii
ri
sss i ipdv
`nnRir
uLo=l sd
o SENDER: I also wish to receive the
'a. Gomplets items 1 and/or 2 for additional services. f
m ■ Complete items 3. 4a, and 4b. fo0owing services (for an
• s PmV your name and address on the reverse of Oft town so that we can return this extra tee):
card to you.
■ Attach this form to the front of the mallpiaoe, or on the (Sack if space does not 1. ❑ Addressee's AddressPermit-
m ■write Retum Receipt Requested' on the madpiece below the adide number. 2. ❑ Restricted DeWery
■The Retum Receipt will show to whom the article was delivered and the date
C deovered. Consult postmaster for fee. i
n �f
V3SZmssedto: a Number
E
/ / 4b, Service T
fi o �4' 0 Registe L�j44� rtified
0 Exrre M �� Insured
'eve 0 Retum COO
7. Date o �r
3�
T
5. Received By: (Punt Name) 6. Addressee > e- ifrtaquestad
and fee is paid)
3 6. Signature: dd or Agent)
a°.
is -
m
PS Form 3811, Dkember 1994 102595-97-i3-a179 Domestic Retum Receipt

� SSATf a
ra
State of North Carolina
Department of Environment, Health, and Natural Resources
Wilmington Regional Office
James B. Hunt, Jr. Division of Water Quality Jonathan B. Howes
Governor
May 19, 1997
el a I ►l M1 all
I V. 1 i 41 ry sl
Ricky Barnes
Barnes Farms Inc.
-3695 Kings Cross Road
Lumberton, NC 28358
Dear Mr. Barnes:
Secretary
Subject: NOTICE OF DEFICIENCY
Barnes Farms Inc.
Facility Number: 24-107
Columbus County
On May 15, 1997, staff from the Wilmington Regional Office of the Division of Water Quality
inspected your animal operation and the lagoon(s) serving this operation. It was observed that erosion cuts
and other bare areas on the lagoon wall could threaten the integrity of the structure. In addition, the
stormwater drainage path from the houses is starting to erode the toe of the lagoon wall.
As we discussed, the erosion cuts in the lagoon wall should be filled and revegetated. Other bare
areas on the lagoon wall should also be revegetated. In addition, rock fill should be placed in the stormwater
path to slow drainage flows or a pipe should be installed. We suggest that you contact your local NRCS,
or Soil and Water District office for any assistance they may be able to provide to correct these problems.
To remain a deemed permitted facility, you must notify this office in writing within fourteen (14) days
of the receipt of this notice, what actions will be taken to comply with your waste management plan. Failure
to do so may result in the facility losing it's deemed permitted status, requiring it to obtain an individual non
discharge permit.
127 Cardinal Drive Extension, Wilmington, N.C. 28405-3845 • Telephone [phone] • Fax [phone]
An Equal Opportunity Affirmative Action Employer

Ricky Barnes
May 19, 1997
Page 2
Please be aware it is a violation of North Carolina General Statutes to discharge wastewater to the
surface waters of the State without a permit. The Division of Environmental Management has the authority
to levy a civil penalty of not more than $10,000 per day per violation.
If you have any questions concerning this matter, please call Andy Helminger, David Holsinger, or
Brian Wrenn at 910-395-3900.
Sincerely,
Andrew G. Helminger
Environmental Specialist
cc: Donna Register, County Soil and Water Conservation
Sandra Weitzel, NC Division of Soil and Water Conservation
Operations Branch
Wilmington Files
S. I WQSV ADYA 12¢I0ZDEF

r ❑ DSWC A`a Feedlot et — w x
><mai O a on Re e
��,
s �($DWQ-Animal Fee dlot Operation Site'.Iaspection`
- � •-+- _.r 5-.-,.-:_ - -..'� :..i -: s}., xs--mot `> n T'- c f-�
_ ,r
r- .l9 Routine Q Complaint 0 Follow-up of DCVO inspection O Follow-uo of DSWC review O Other
Facilitv dumber
Farm Status- Ce­
Total Time (in hours) Spent onAeview
or Inspection (includes travel and processing)
Farm Name: .Ldx--,a. . 4 — .5 I v% c_ . County: — -0-1 .) V%A
Owner Name:. ; -Y=!4 1Z a �r tn e-9 - Phone No: (RIO 2,31-(RI 19 1 .S X
Mailing Address: 'I C 5 e - 10 yA JQ
Onsite Representative: $o��r Integrator: �-a v v r . �r ._
Certified Operat❑r. Operator Certification Number:
Location of Farm:
Latitude ©• E s-1, S Longitude
❑ Not Operational Date Last Operated:
1'�Te of Operation and Design Capacity
� .+}w-- f. ". - '-:' b Z � -' N• � �> � - ' ;.. K' -ti: «
r �... Yaul .,°{- \nmber Cattie '_' r
..r"N&13ib -
F
.L�timber
❑ Wean to Feeder
❑ Laver I
M'• ❑ Dairy
w 0 Feeder to Finish
p . � »�: ❑ Non -Laver I
� ❑Beef
Farrow to Wean
'.Ms'
--i1'
.'.
S 'X '^ _�'.[. a"w`S>t•' .MAR Ymw,. +w�F..`l+T',�-.',7.i T"- �Jn-'>�t X��c � _
1k D Farrow to Feeder
Farrow to Finish ��- Other Type of Livestoci:
'
k
_
��: ��2"-'�-Y >"T /^'- ..x> t.. -'ti:r\:.+...a•" -: :. �' .:.. £" :... �. ..,Y.S+`k.- .�f- !6 �----.'fiYYW T.-K _
�1\umber oils oaflsl HbldzngPondsY: ❑ Subsurface Drains Present
cnn}` -�❑ Lagoon Area ❑ Spray Field Area ;
General
I. Are there any buffers that need maintenance/improvement? ❑-Yes 19 No
2. Is any disc:,arzZe observed from any part of the operation? ❑ Yes 9 No
a If discharge is observed, was the conveyance man-made? ElYes ® No
b. If discharge is observed, did it reach Surface Water? (If yes, notify Day Q) ❑ Yes R NO
c. If discharge is observed, what is the estimated flow in gal/min? 01 A
d. Does discharge bypass a lagoon system? (If yes, notify DWQ) El Yes ®No
Is there evidence of past discharge from any part of the operation? ElYes EN
4. Was there anv adverse impacts to the waters of the State other than from a discharge? ❑ Yes E 'o
S. Does any part of the waste management system (other than lagoons/holdiner ponds) require ❑ Yes 9No
rraintenanc Blimp rovemcnr?
Continued atr !pack

6. Is facility not in compliance with any applicable setback criteria?'.""
7. Did the facility fail to have a certified operator in responsible charge (if inspection after 1/l/97)?
8. Are there lagoons or, storage ponds on site which need to be properly closed?
Structures {Laf oohs and/or Holding Pondsl
9. Is structural freeboard less than adequate?
Freeboard (ft): Lagoon 1 Lagoon 2 Lagoon 3
10. Is seepage observed from any of the structures?
11. Is erosion, or any other threats to the integrity of any of the structures observed?
12. Do any of the structures need maintenance/improvement?
(If any of questions 9-12 was answered yes, and the situation poses an
immediate public health or environmental threat, notify DWQ)
13. Do any of the stnictures lack adquate markers to identify start and stop pumping levels?
Waste Application
14. Is there physical evidence of over application?
(If in excess of WMP, or runoff entering waters of the State, notify DWQ)
15. Crop type is w►v t4"1 rt
16. Do the active crops differ with those designated in the Animal Waste Management Plan?
17. Does the facility have a lack of adequate acreage for land application? _
18. Does the cover crop need improvement?
19. Is there a lack of available irrigation equipment?
For Certified Facilities Oniv. .
20. Does the facility fail to have a copy of the Animal Waste Management Plan readily available?
21. Does the facility fail to comply with the Animal. Waste Management Plan in anyway?
22. Does record keeping need improvement?
23. Does facility require a follow-up visit by same agency?
24. Did ReviewevluVector fail to discuss reviewimspection with owner or operator in charge?
❑ Yes
B No
❑ Yes
PTNo w
❑ Yes
E?No
❑ Yes
® No
Lagoon 4
❑ Yes
9[No
Yes
❑ No
Yes
❑ No
❑ Yes
9No
❑ Yes
19No
❑ Yes KNo
❑ Yes Mtio
❑ Yes KIND
❑ Yes Callo
❑ Yes ff No
❑ Yes ISNo
❑ Yes ENO
R[ Yes ❑ No
❑ Yes Zvo
11.111,� V -a S I 0 r. t v f s o r4 iom r L. u_ r e_ a. S W e,rC_ 0 b .i e•v Vk_,k 0-v'tl u ✓,t,L f 1n ,e Q K't P' rt . 4
Walk o0". T-es4 cut-S V%e._;�_k C,14 V_t'V £[R
�✓1 V ��� �l0+ny at1 d�(.er` bv-re a,r-e-.4-3 0, e 1� dog Wa11 HEw
fp
�ILaf Zt �.)aS also 0 �Sea �L.Q S{LOOLt
�. ..,., t z Itio v s e n ; s ,• �- i`o g.�a d 2_
Q_ t`k
a t Jt l 00 �^ w a t t. R o z k s r. e e-ct {b b e PL cRa_ I` , EA.% t,
V` P d �l �o slow �ti^ ke ¢ o r ...-, w c1 i 2-�r l0 .�5 o fi CA- Jr I
IvL aLot S v r e iro t �e{ W a 4 S t V_ 0. via (_ i �> S J o vt - r j lti F h r
vut� ��rSf & jFY—", . sel o v�--� cis also h�s
aC 1e-QS{r n—r 0 _ r. LA
Reviewer/Inspector Name
Reviwer/Inspector Signature:
cc: Division of Water Oua1hy, Water Quality, Section, Facility Assessment Unit
Date:
11/14/96

[fir
d `
�_ _....
t;
--- _.._ .... _.. _ i:;4JA-ter_+._,.?__ _�A_.i-f'►�r�Y_-..d,l'i"ti� � - --------- -- — ..._. _
A -
-
�., 7I�C .2g�5
r:
ale -
Gnu
.......--
t
�z`

Le
>
Aj
Al
I
I
WL-7 --a
Ll
to
3>
0
C-) rq
0
-q
rrl
tv
- z