240006_HISTORICAL_20171231

NUH I H UAHULINA
Department of Environmental Qual

Environmental
Quality
Bray Cole Anders
Anders Farm
1138 Baybride Drive
Dillon, SC 29536.
Dear Bray Cole Anders:
ROY COOPER
Governor
MICHAEL S. REGAN
Secretary
S. JAY ZIMMERMAN
Director
RECEIVEDJNCDENMk%t 25, 2017
AUG 2 S 2017
Water Quasi @8i' Certificate of"Coverage No. AWS240006
Operationsedon Anders Farm
Wilmington Regional Office
Swine Waste Collection, Treatment,
Storage and Application System
Columbus County
In accordance with your Notification of Change of Ownership received August 24, 2017, we are hereby
forwarding to you this Certificate of Coverage (COC) issued to Bray Cole Anders, authorizing the operation
of the subject animal waste management system in accordance with General Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management Plan
(CAWMP) for Anders Farm, located in Columbus County, with a swine animal capacity of no greater than
the following annual averages:
Wean to Finish: Feeder to Finish: 4, 8% Boar/Stud:
Wean to Feeder: Farrow to Wean: Gilts:
Farrow to Finish: Farrow to Feeder: Other:
If this is a Farrow to Wean or Farrow to Feeder operation, there may be one boar for each 15 sows. Where
boars are unnecessary, they may be replaced by an equivalent number of sows. Any of the sows may be
replaced by gilts at a rate of 4 gilts for every 3 sows.
This COC shall be effective from the date of issuance until September 30, 2019, and shall hereby void
Certificate of Coverage Number AWS240006 dated October 1, 2014. Pursuant to this COC, you are
authorized and required to operate the system in conformity with the conditions and limitations as specified
in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting and
maintaining the required monitoring data and operational information must be established for this facility.
Any increase in waste production greater than the certified design capacity or increase in number of animals
authorized by this COC (as provided above) will require a modification to the CAWMP and this COC and
must be completed prior to actual increase in either wastewater flow or number of animals.
Please read this COC and the enclosed State General Permit carefully. Please pgy careful attention to the
record keeping and monitoring conditions in this permit. Record keeping forms are unchanged with this
General Permit. Please continue to use the same record -keeping forms.
State of North Carolina I Environmental Quality I Division of Water Resources
Water Quality Regional Operations Section
1636 Mail Service Center I Raleigh, North Carolina 27699-1636
919-707-9129

If your Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
The issuance of this COC does not excuse the Permittee fr6m.the obligation.to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Per NRCS standards a 100-foot separation shall be maintained between water supply wells and any lagoon,
storage pond, or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting,the Animal Feeding Operations Program for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition H.22 of the General Permit, waste application shall cease within four (4)
hours -of the time that -the National Weather Service issues a Hurricane Warning, Tropical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You may
find detailed watch/warning information for your county by calling the Wilmington, NC National Weather
Service office at (910) 7624289, or by visiting their website at: bttp://www.weather.gov/ilm/
This facility is located in a county covered by our Wilmington Regional Office. The Regional Office staff
may be reached at 910-796-7215. If you need additional information concerning this COC or the General
Permit, please contact the Animal Feeding Operations Program staff at [phone].
Sincerely,
J�
for S. Jay Zimmerman, P.G.
Director, Division of Water Resources
cc: (Certificate of Coverage only for all ccs)
Wilmington -Regional Office, Water Quality Regional Operations Section
Columbus County Health Department
Columbus County Soil and Water Conservation District
WQROS Central Files (Permit No. AWS240006)
Smithfield Hog Production

Environmental
Quality
August 25, 2017
Bray Cole Anders
Anders Farm
1138 Baybride Drive
Dillon, SC 29536
ROY COOPER
Governor
MICHAEL S. REGAN
Secretary
S. JAY ZIMMERMAN
Director
Subject: Certificate of Coverage No. AWS240006
Anders Farm
Swine Waste Collection, Treatment,
Storage and Application System
Cohunbus County
Dear Bray Cole Anders:
In accordance with your Notification of Change of Ownership received August 24, 2017, we are hereby
forwarding to you this Certificate of Coverage (COC) issued to Bray Cole Anders, authorizing the operation
of the subject animal waste management system in accordance with General Permit AWG 100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management Plan
(CAWMP) for Anders Farm, located in Columbus County, with a swine animal capacity of no greater than
the following annual averages:
Wean to Finish: Feeder to Finish: 4, 996 Boar/Stud:
Wean to Feeder: Farrow to Wean: Gilts:
Farrow to Finish: Farrow to Feeder: Other: /
If this is a Farrow to Wean or Farrow to Feeder operation, there may be one boar for each 15 sows. Where
boars are unnecessary, they may be replaced by an equivalent number of sows. Any of the sows may be
replaced by gilts at a rate of 4 gilts for every 3 sows.
This COC shall be effective from the date of issuance until September 30, 2019, and shall hereby void
Certificate of Coverage Number AWS240006 dated October 1, 2014. Pursuant to this COC, you are
authorized and required to operate the system in conformity with the conditions and limitations as specified
'in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting and
maintaining the required monitoring data and operational information must be estabMe d for this facility.
Any increase in waste production greater than the certified design capacity or increase in number of animals
authorized by this COC (as provided above) will require a modification to the CAWMP and this COC and
must be completed prior to achW increase in either wastewater flow or number of animals.
Please read this COC and the enclosed State General Permit carefully_ Please gay careful attention to the
record keening and monitoring conditions in this pernrit. Record keeping forms are unchanged with this
General Permit. Please continue to use the same record keeping forms.
soft of North CuW= I F "=ncc al Qtmkty I Divm= of water Rmwr es
wafer QwduI' Rlotatl opersams seetloa
1636 Mail Service Center j Rah4jk North Carolhu 27699-16M
919-707-9129

If your Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation- of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Per NRCS standards a l00-foot separation shall be maintained between water supply wells and any lagoon,
storage pond, or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Program for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition I1.22 of the General Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Tropical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You may
find detailed watch/warning information for your county by calling the Wilmington, NC National Weather
Service office at [phone], or by visiting their website at: bo://www.weather.govrilni/
This facility is located in a county covered by our Wilmington Regional Office. The Regional Office staff
may be reached at 910-796-7215. If you need additional information concerning this COC or the General
Permit, please contact the Animal Feeding Operations Program staff at [phone].
Sincerely,
J
Lor S. Jay Zimmerman, P.G.
Director, Division of Water Resources
cc: (Certificate of Coverage only for all ccs)
Wilmington Regional Office, Water Quality Regional Operations Section
Columbus County Health Department
Columbus County Soil and Water Conservation District
WQROS Central Files (Permit No. AWS240006)
Smithfield Hog Production
I

- .3
Gc1 � 1°D �k-PS
y=WASTE�nUT1LtZAT ONPLAN��: .
h
PRODUCER:
LOCATION:
TELEPHONE:
TYPE OPERATION:
NUMBER OF ANIMALS
(Design Capacity)
Darrell Stocks Farm
Hwy 904
Columbus County
910-653-9386
Feeder - Finish
4896
RECEIVED / DENR 1 DWQ
AQUIFFa-PPnTrrT10N SECTION
J&.11 ZOO7a
14 N 1 9 2007
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface and/or groundwater. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops in the fields where the waste is
to be applied. This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be
analyzed before each. application cycle. Annual soil tests are strongly encouraged so that all
plant nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and available water holding capacities. Normally waste shall not be applied to land
eroding at greater than 5 tons per acre per year. With special precautions, waste may be
applied to land eroding at up to 10 tons per year. Do not apply waste on saturated soils, when it
is raining, or when the surface is frozen. Either of these conditions may result in runoff to
surface wafers which is not allowed under DEM regulations. Wind conditions should also be
considered to avoid drift and downwind odor problems. To maximize the value of nutrients for
crop production and to reduce the potential for pollution, the waste should .be applied to a
growing crop or applied to bare ground not more than 30 days prior to planting- Injecting the
waste or disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for analysis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H.0217 adopted by the Environmental Management Commission.
Page 1

Amount of Waste Produced Per Year (gallons, ft, tons, etc.)
4,896 animals X 1_9 (tons) waste/animal/year =
Amount of Plant Available Nitrogen (PAN) Produced Per Year
4,896 animals X 2.3 lbs. PAN/animal/year
Guide Std. 633)
9,302 (tons) waste/year.
11,261 lbs. PAN/year. (PAN from N.C.
Tech
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner
The following acreage will be needed for waste application based on the crop to be grown and
surface application:
Table 1: ACRES OWNED BY PRODUCER
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
# No. Type Per Acre Utilized Application
T6506
1
NoB
Bermuda (G)
2601
9.49
2467.4
March - Sept
T6504
2
NoMy
Bermuda (G)
245
8.70
2131.5
March - Sept
T6504
3
FoA
Bermuda (G)
255
2.92
744.E
March - Sept
T6504
4
Ly
Bermuda (G)
225
11.81
2657.25
March - Sept
T6504
5
L INoA
Bermuda (G)
245
1.97
482.65
March - Sept
1-5
Small Grain
50
34.89
1744.5
Se t - April
T6504
6
Ly
Millet
120
5.84
700.8
March - Sept
T6504
6
L
Small Grain
75
5.84
438
Sept - April
T6504
6
Ly
Soybeans
156
5.84
911.04
June - Sept
0
0
0
0
Total 1 40.731 11, 366.70 1
*This N is from animal waste only. If nutrients from other sources such as commercial fertilizer are
applied, they must be accounted for. N must be based on realistic yield expectation.
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N
requirements. Beginning in 1996 the Coastal Zone Management Act will require farmers in some
eastern counties of North Caroline to have a nutrient management plan that addresses all nutrients.
This plan only addresses Nitrogen.
Pulls
1,2,3,4
5,6,7,8
9
10,11,13
15
16,17
Page 2

o-= � - as .� �"`"'4*y="'^'a""`rr��-r .:n.. - �aa t•.-.u�-'^.vty^� i e�`"�,P-......�„r ,� - �-''qc-C
r r ASTE:UTFL1ZATlON PLAN
'cable T: ACRES OWNED BY PRODUCER
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
# No. Type Per Acre* Utilized Application Pull
T6504
7
GoA
Soybeans
120
3.51
421.20
June - Sept
18
T6504
7
GoA
Wheat
144
3.51
505.44
Sept - April
T6504
7
GoA
Corn
135
3.51
473.85
March - July
T6504
8
GoA
Soybeans
120
2.77
332.40
June - Set
19
T6504
8
GoA
Wheat
144
2.77
398.88
Sept - April
T6504
8
GoA
Corn
135
2.77
373.95
March - Jul
T6504
9
GoA iSoybeans
120
6.24
748.80
June - Sept
20
T6504
9
GoA
Wheat
144
6.24
898.56
Sept - April
T6504
9
GoA
Corn
135
6.24
842.40
March - Jul
T6504
9
GoA
Tobacco
50
6.24
312.00
30 Days preplant
T6504
9
GoA
Bermuda (G)
243
6.24
1,516.32
Sept - April
T6504
10
Ly
Millet (G)
120
4.51
541.20
March - Sept
21
T6504
10
Ly
Soybeans
156
4.51
703.56
June - Sept
T6504
10
Ly
Small Grain
75
4.51
338.25
Sept - April
17.0
1,403.85
TOTAL
Page 10

Table 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowner must be attached)
(Required only if operator does not own adequate land [see
Required Specification 2])
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
# No. Type Per Acre Utilized • ..
* See footnote for Table 1.
Totals from above Tables
Acres Lbs. N
Utilized
Table 1 40.73 11,367
Table 2 0.00 -
Total 40.73 11,367
Amount of N Produced 11,261
Surplus or Deficit (106)
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to prevent over
application of nutrient or other elements.
Page 3

�: 4 x ..x, ,T'� -"- 'i *��-.-,-.r�-rxT•..��"�r�aF� .s7--a•� .�" � `may„ ._. �,_.� -�iaIlal{A�S,�TEP,. ..r c; �:n >� :"-'�'-, _'�-asa-s•--Y-'-> - "S� -- =""' - e �. lr _UTiWZAT10NP.a_ �_
'
See attached map showing the fields to be used for the utilization of waste water.
Application of Waste by Irrigation
Field Soil Type Crop Application Application
No_ Rate (In/Hr) Amount (In.)
1
NoB
Bermuda
0.5
1.0
2,5
NoBILy
Bermuda
0.5
1.0
3
Fo
Bermuda
0.5
1.0
4
Ly
Bermuda
0.5
1.0
6
Ly
Millet
0.5
1.0
7,8,9
GoA
Row Crops
0.5
1.0
THIS TABLE IS NOT NEEDED IF WASTE IS NOT BEING APPLIED BY IRRIGATION, HOWEVER A SIMILAR TABLE
WILL BE NEEDED FOR DRY LITTER OR SLURRY.
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 MONTHS. In no instance should the volume of
waste being stored in your structure exceed Elevation *see lagoon design.
Call the local Natural Resources Conservation Service (formerly Soil Conservation Service) or Soil
and Water Conservation District office after you receive the waste analysis report for assistance in
determining the amount per acre to apply and the proper application rate prior to applying the
waste.
Narrative of operation Acres shown are "wetted". All land may be grazed. All bermuda will
be overseeded. Fields 7,8,9 are optional and grower may plant any of the crops listed on page 10.
Field 6 grower has the option of planting millet and small grain or soybeans and small grain. if
soybean option used, grower must deduct 15 lbs PAN from small grain crop.
Page 4

REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of waste, he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing him/her the
use of the land for waste application_ It is the responsibility of the owner of the facility to
secure an update of the Waste Utilization Plan when there is a change in the operation,
increase in the number of animals, method of utilization, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climatic conditions, and level
of management, unless there are regulations that restrict the rate of application for other
nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but less than 10 tons per acre per
year providing grass filter strips are installed where runoff leaves the field. (See FOTG
Standard 393 - Filter Strip).
Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6 When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland,
the waste may be broadcast provided the application does not occur during a season
prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor or flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen_
Page 5

S"�x"°,``` %-.. --ar`�;i�-�c"�"��ca-,� zr�-°.»...�.._�s--'�'•--�ar� -x rx .4s^'S".�R ,.,�.��, -.�a "�-:.:
3�
��
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a
high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste
shall not be applied more than 30 days prior to planting of the crop or forages breaking
dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following. -
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and from any perennial stream or river (other than an irrigation ditch or canal. Animal
waste other than swine waste from facilities sited on or after October 1, 1995), shall not be
applied closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips).
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site by a "technical specialist".
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
Page 6

REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced as necessary to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied pre -plant with no further applications animal waste
during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste analysis records shall be kept
for five years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
23
Dead animals will be disposed of in a manner that meets North Carolina regulations.
Page 7

'� -�° � �-�'," r.x'�`" -, ., m �^ ^5n" :vr*.:�k..�».wr- �n'.`r^�:'-ar•.a-��w: at. �'�"'� �":.�.��'T' �-� #�-� '7�
t� -w; WASTE=UTILIZATI4N PLAN ;Ma
��
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: Darrell Stocks Farm
Owner / Manager Agreement
I (we) understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. I (we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new facilities will require a new
certification to be submitted to the Division of Environment Management (DEM) before the
new animals are stocked. I (we) also understand that there must be no discharge of
animal waste from this system to surface waters of the state from a storm event less severe
than the 25-year, 24-hour storm. The approved plan will be filed on -site at the farm office
and at the office of the local Soil and Water Conservation District and will be available for
review by DEM upon request.
Name of Facility Owner: Darrell Stocks
(Please print)
Signature: Date: 'Fjr "ef".1k
Name of Manager (If different from owner):
Signature:
Date:
Name of Technical Specialist: (Please print) Toni W. King
Affiliation: Murphy - Brown
Address (Agency): P.O. Box 856
Warsaw, NC 28398
Signature: --- UO' - 1�\ Y-- Date: 3 aS
Page 8

4W
Type of Visit oCompliance Inspection 0 Operation Review 0 Lagoon Evaluation
Reason for Visit 0 Routine 0 Complaint 0 Follow up 0 Emergency Notification 0 Other ❑ Denied Access
Facility Number Z Date of Visit: O L Time: I 10 : DD
Not O erational 0 Below Threshold
0 Permitted © Certified [3ConditionallyLCertified ©Registered pate Last Operated or Ahove Threshold
Farm Name: w �� ✓rB�/ _574,, s., Es �'`^ County: Col Vim► byS ._
Owner Name:7A r/e 11 S-�a e. �s Phone No:
Mailing Address:
Facility Contact: 1 Title: Phone No:
Onsite Representative: 04 Integrator: % irN'�%f'► 4
Certified Operator: Operator Certification Number:
Location of Farm:
❑ Swine ❑ Poultry ❑ Cattle ❑ Horse Latitude a I Du Longitude • 1
Desin CurrentDesin ren#
,D#v;=. Current r= . Cu
PPPo ulation PotitrrCall caaa aeitvo ila>Za€t
El El
to Feeder ❑ Layer mm
El Feeder to Finish ❑Non -Layer
r
Farrow to Wean v
El Farrow to Feeder ��� ❑Other
❑ Farrow to Finish M` Total Design Capacity'
❑ Gilts
❑ Boars -- k Tot81 SSLW
Numlaer of Lagooii5 © ❑Subsurface Drains Present ❑ La oon Area ❑ S ra
1id.Trp ❑Liquidy Field Area
°HoldtagPondsl.-Soa s
_ <_ :. No Li uid Waste Mana ement System i
❑ Da'
❑ Non -Dairy
Discharges & Stream Impacts
1. Is any discharge observed from any part of the operation?
Discharge originated at: ElLaizoon Cl Spray Field El Other
a. If discharge is observed, was the conveyance man-made?
b. If discharge is observed, did it reach Water of the State? (if yes, notify DWQ)
c. if discharge is observed. what is the estimated flow in gal/min?
d. Does discharge bypass a lagoon system? (If yes, notify DWQ)
2. Is there evidence of past discharge from any part of the operation?
3. Were there any adverse impacts or potential adverse impacts to the Waters of the State other than from a discharge?
Waste Collection & Treatment
4. Is storage capacity (freeboard plus storm storage) less than adequate? El Spillway
Structure I Structure 2 Structure 3 Structure 4 Structure 5
Identifier: I
Freeboard (inches): 3
05103101
❑Yes ❑ No
❑ Yes ❑ No
❑ Yes ❑ No
❑ Yes ❑ No
❑ Yes ❑ No
❑Yes ❑ No
Ely es
o
�N
Structure 6
Continued

1 •�
Facility Number: Zq — Date of Inspection
5. Are there any immediate threats to the integrity of any of the structures observed9-0c/ trees, severe erosion, ❑ Yes ❑ No
seepage, etc.)
6. Are there structures on -site which are not properly addressed and/or managed through a waste management or
closure plan? ❑ Yes ❑ No
(If any of questions 4-6 was answered yes, and the situation poses an
immediate public health or environmental threat, notify DWQ)
7. Do any of the structures need maintenance/improvement? ❑ Yes ❑ No
& Does any part of the waste management system other than waste structures require maintenance/improvement? ❑ Yes ❑ No
9. Do any stuctures lack adequate, gauged markers with required maximum and minimum liquid level
elevation markings? ❑ Yes ❑ No
Waste Application
10- Are there any buffers that need maintenance/improvement? ❑ Yes ❑ No
11. is there evidence of over application? ❑ Excessive Pending ❑ PAN ❑ Hydraulic Overload ❑ Yes ❑ No
12. Crop type
13. Do the receiving crops differ with those designated in the Certified Animal Waste Management Plan (CAWMP)? ❑ Yes ❑ No
14. a) Does the facility lack adequate acreage for land application?
❑ Yes
❑ No
b) Does the facility need a wettable acre determination?
❑ Yes
❑ No
c) This facility is pended for a wettable acre determination?
❑ Yes
❑ No
15. Does the receiving crop need improvement?
❑ Yes
❑ No
16. Is there a lack of adequate waste application equipment?
❑ Yes
❑ No
Required Records & Documents
17. Fail to have Certificate of Coverage & General Permit or other Permit readily available?
❑ Yes
❑ No
18. Does the facility fail to have all components of the Certified Animal Waste Management Plan readily available?
(ic/ WUP, checklists, design, maps, etc.)
❑ Yes
❑ No
19. Does record keeping need improvement? (ie/ irrigation, freeboard, waste analysis & soil sample reports)
❑ Yes
❑ No
20. Is facility not in compliance with any applicable setback criteria in effect at the time of design?
❑ Yes
❑ No
21. Did the facility fail to have a actively certified operator in charge?
❑ Yes
❑ No
22. Fail to notify regional DWQ of emergency situations as required by General Permit?
❑ Yes
❑ No
(ie/ discharge, freeboard problems, over application)
23. Did Reviewer/Inspector fail to discuss revicw/inspection with on -site representative?
❑ Yes ZNo
24. Does facility require a follow-up visit by same agency?
❑ Yes
❑ No
25. Were any additional problems noted which cause noncompliance of the Certified AWMP?
❑ Yes
[]No
LE3 No violations or deficiencies were noted during this visit. You will receive no further correspondence about this visit.
Comments (re€erWt s:questioi€ #).- Ezplatpally YES a�er's and/or. any recommendstions_or anv _© `hi er.cAiiii
Use drawings of facility to"better explain situations:"(nse addiiional pages`ss nefessarv} ores
. _ - _ j❑-Field Coflv�❑ Final N
- _
S c.onef vrJed 41i i S i -1s��c ; o i ►1 �/'es f�T'!SQ �o Gt Ga•�iJO f�t:.t vd ar
and Mal ot.��-Flow s��.,, yja ev;d�tgsp 010 et 5e.
be-
-T I,e oda� be .�e��r�ed ila �Lr� 1��v, f�d�
e z� - leg00
-r,'Aie OlJ4 = 1l = ZO
Reviewer/Inspector Name h-
Reviewer/Inspector Signature: Date:
05103101 Continued

Michael,F.' Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Coleen H. Sullins, Director
Division of Water Quality
July 1, 2007IVED
Darrell Stocks
Darrell Stocks Farm JUN S 6 2007
12559 Swamp Fox Hwy E
Tabor City, NC 28463�`
Subject: Certificate of Coverage No. AWS240006
Darrell Stocks Farm
Animal Waste Management System
Columbus County
Dear Darrell Stocks:
In accordance with your application received on 18-Jan-07, we are hereby forwarding to you this
Certificate of Coverage (COC) •issued to Darrell Stocks, authorizing the operation of the subject animal
waste management system in accordance with General Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for the Darrell Stocks Farm, located in Columbus County, with an animal capacity of no
greater than the following swine annual averages:
Wean to Finish: 0 Feeder to Finish: 4896 Boar/Stud: 0
Wean to Feeder: 0 Farrow to Wean: 0 Gilts: 0
Farrow to Finish: 0 Farrow to Feeder: 0
If this is a Farrow to Wean or Farrow to Feeder operation, there may also be one boar for each 15 sows.
Where boars are unneccessary, they may be replaced by an equivalent number of sows. Any of the sows
may be replaced by gilts at a rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009 and replaces the NPDES
COC issued to this facility with an expiration date of July 1, 2007. You are required to continue
conducting annual surveys of sludge accumulation in all lagoons at your facility; the one-year extension
in Condition IIL19 does not apply.
Pursuant to this COC, you are authorized and required to operate the system in conformity with the
conditions and limitations as specified in the General Permit, the facility's CAWMP, and this COC. An
adequate system for collecting and maintaining the required monitoring data and operational information
must be established for this facility. Any increase in waste production greater than the certified design
capacity or increase in number of animals authorized by this COC (as provided above) will require a
modification to the CAWMP and this COC and must be completed prior to actual increase in either
wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Enclosed for your convenience is
a package containing the new and revised forms used for record keeping and reporting. PleaseRay
careful attention to the record keeping and monitoring conditions in this permit.
Aquifer Protection Section 1636 Mail Service Center
Internet: www.newaterquahimig Location: 2728 Capital Boulevard
An Equal Opportunity/Affirmative Action Employer— 50°% Rerycledl10°% Past Consumer Paper
N�ba�thhCarolina
)VA?& I1
Raleigh, NC 27699-1636 Telephone: [phone]
Raleigh, NC 27604 Fax 1: [phone]
Fax 2: [phone]
Customer Service: [phone]

If your Waste Utilization Plan has been developed based on site -specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, .rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
' under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility. , ' s • '
Per 15A NCAC 02T .0111(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per MRCS standards a 100-foot separation
shall be maintained between water. supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Per 15A NCAC 02T .1306, any containment basin, such as a lagoon or waste storage structure, shall
continue to be subject to the conditions and requirements of the facility's permit until closed to NRCS
standards and the permit is rescinded by the Division.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Wilmington Regional Office. The Regional Office
Aquifer Protection staff may be reached at 910-395-3900. If you need additional information concerning
this COC or the General Permit, please contact the Animal Feeding Operations Unit staff at (919) 733-
3221.
Sincerely,
for Coleen H. Sullins
Enclosures (General Permit AWG100000, Record Keeping and Reporting Package)
cc: (Certificate of Coverage only for all cc's)
Columbus County Health Department
Columbus County Soil and Water Conservation District
Wilmington Regional Office, Aquifer Protection Section
AFO Unit Central Files
Permit File AWS240006

0�0 W A T �RQG
O 'C
November 19, 2007
Darrell Stocks
Darrell Stocks Farm
12559 Swamp Fox Hwy E
Tabor City, NC 28463
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Coleen H. Sullins Director
Division of Water Quality
Subject: Sludge Survey Testing Dates
Certificate of Coverage No. AWS240006
Darrell Stocks Farm
Animal Waste Management System
Columbus County
Dear Darrell Stocks:
The Division of Water Quality (Division) received your sludge survey information on November
15, 2007. With the survey results, Kathy Dugan requested an extension of the sludge survey
requirement for the lagoon at the Darrell Stocks Farm facility not to be required until 2009: Due
to the amounts of treatment volume available, the Division agrees that a sludge survey is not
needed until 2009. The results of the 2009 sludge survey are to be submitted by March 1, 2010.
Thank you for your attention to this matter. if you have any questions, please call me at (919)
715-6937.
Sincerely,
7*44---p
Miressa D. Garoma
Soil Scientist
cc: Wilmington Regional Office, Aquifer Protection Section
Kathy Dugan
Central Files
Aquifer Protection Section 1636 Mail Service Center
Internet: www.newateraualitv.ore, Location: 2728 Capital Boulevard
An Equal Opportunity/Affirmative Action Employer- 50% Recycledll0% Post Consumer Paper
NorthCarolina
Naturally
Raleigh, NC 27699-1636 Telephone: [phone]
Raleigh, NC 27604 Fax 1: [phone]
Fax 2: [phone]
Customer Service: [phone]

t
►-,63/03/2007 17:03 9104232212 GALL9ERRY (ON PAGE 06
ANUdAL FACI M ANNUAL CERTIFICATION FORM
Certificate of Coverage oar Permmit Number C County (!y 1uftjzu s Year 200k
Facility Name (as shown on Certificate of Coverage or Permit) L_r
Operator in Charge for this Facility &ir Certification #
Land application of animal waste as allowed by the above permit occurred during the past calendar year C
YES NO. If NO, slip Part I and Part 11 and proceed to the certittficatioa Also, if animal waste was
generated but not land applied, please attach an explanation on how the animal waste was handled.
Part I : Facility Iu&3Batlon:
1. Total number of application Fields 0 or Pulls 0 (please check the appropriate box) in the Certified Animal
Waste Management Plans (CAWMx ): I () Total Useable Acres approved in the CAWMP
55.15
2. Total number of Fields ❑ or'Pulls K(please check the appropriate box) on which land application occurred
during the year: I Q Total Acres on which waste was applied SA. A5
3. Total pounds of Plant Available Nitrogen (PAN) applied during the year for all application sites:
444.3
4. Total pounds of Plant Available Nitrogen (PAN) allowed to be land applied annually by the CAWMP and
the permit: 1 i 3 0
5. Estimated amount of total manure, litter and process wastewater sold or given to other persons and taken
off site during the year ID tons Cl or gallons 0 (please check the appropriate box)
6. Annual average number of animals by type at this facility during the previous year:
LKI �-
7. Largest and smallest number of animals by type at this facility at any one time during the previous year:
Largest
Smallest
(These numbers are for informational purposes only since the only permit limit on the number of animals at
the facility is the annual average numbers)
8. Facility's Integrator if applicable:
Part II: Facility Status:
IF THE ANSWER TO ANY STATEMENT BELOW IS "NO", PLEASE PROVIDE A WRITTEN
DESCRIPTION AS TO WHY THE FACILITY WAS NOT COMPLIANT, THE DATES OF ANY NON
COMPLIANCE, AND EXPLAIN CORRF-CTTVE ACTION TAKEN OR PROPOSED TO BE TAKEN TO
BRING THIS FACILITY BACK INTO COMPLIANCE.
1. Only animal waste generated at this facility was applied to the permitted sites during Yes 0 No
the past calendar year.
AFACF 3-14-03

1 03/03/2007 17:03 9104232212 GALLBEIRY CON PAGE 07
2.
The amity was opmi tad in such a way that there was no Reef runoff of waste fifom
Yes
❑ No
the *=lity (including the houses, *gocnilstwago ponds and the application sites) during
the pest calendar year.
3.
There was no discharge of waste to SU&Mwater $vm this faciity during to past
$ Yes
❑ No
calendar year.
4.
TbM was no fteeboard violation in any lagoons or stamge ponds at this fficiW duu'iag
l� Yes
b No
the past calendar year.
S.
Tba+G ww no PAN a HCR ia® W any fields Or crops at this facility gmter than &e
Yes
❑ No
levels specified is this facility's CA'WMP dining the past calendar year.
6.
All land application equipment was calibmted at least once during to prat caleodar year
$ Yes
❑ No
7.
Sludge accumulation in all lagoons did not exceed the vahune for which the lagoon
l� Yes
❑ No
was dammed or rem the lagoon's mina treamnrmt volume to leas titan tle volume
fur which the lagoon was d"WROd.
8.
A copy of the Aum mi Sludge Survey Farm for this facility is atUrbod tQ this Certifiica im
Yes
❑ No
-9:
Annual'soils acalyshf Wbre pd*dfwd'on, ester ld vitrg et imat Vaste adm ft the
Yes
❑ No
Past calendar year.
10 Soil pH was mWnbined as specified in the permlt during the past calendar Year? A Yes ❑ No
11. All regard moniU mg and reporting we performed in accordance with the facility's OYes ❑ No
pe;rnat during the Past Calendar year.
12. All operations and mahomwm few in the permit wee complied with curing Yes ❑ No
the past calendar year or, in the case of a deviation, prior audxwi;wtiw was received
from the MASion of water Quality.
13. C Cps as specified in the CAWMP were maiaMinad during the past year cn all Yes ❑ No
sites recmvmg animal waft and the c: mW grown were removed in acourdium with
tbra thciliiy's PQmit
14. All buffer requimmmu as specified on the pe At and the CAWW for Luis facility ve !� Yes ❑ No
maimed during each application of animal waste dmag time past calendar year_
"I ea ft under Penalty of law that this document and all auacbmenb were under my dam or
supervision in accordance with a system shed to ague that qualified peasomel properly pow and
evaluate the information submitted. Based on my inquiry of the parsom or pessans who manages the system, or
those pears w directly re p=z1&.for gadwing the infnrmadc a, the b6mmadon mbwhted is, to the best of
my imowle p and bcllef, true; aocinate� and complete_ I amaware that there are dgmficant penalties for
su mdtfg #'wise Info nwhon, Mcludm the p mb ft of
etzd impli. emt for lomwing vialatiaas."
_ I JaYYt: l l 5n�
Penm tee Name: and Title ( or
Signature of Pemmittee Date
Sigaat c of Operator in ChwF
(if diffivent from Pam)
AFACF 3-14-M
Fa
Date

! 03/03/2007 17:03 9104232212 GALLBERRY CON
PAGE 08
Appendix 1. Iwgooa SlWp 8wv#,7 Form
A. Futn Perm it or DWQ Idettditcation Number le
S. a Idendfication
C. Paroon(s) Taking Met>stuemems Dourall
D. Dolo of Measurements `
R, MeibodwDevices Used for Meastarernettt of
a. Dinaaco from the lagoon liquid sorfte to the top of the sludge layer:
agg
b. DisWm flat ftpgop liquid stttlboe W the I n F- n a (aaml) mf the logo=:
G Thici<n fides dud) lalw if making a. direct m ea numneos with -Owe swupW'
F. LWon Surface Area (use dimensions at inside toy of bankk . 4 {mixes)
(Draw a alcsteh of tho lagoon on a separate aim, ho dinwosims, nand celattaae surfam area.)
G. Esturude mrnber of sampling pa>MIL
a. Less thorn 133 alms: Use 8 mts
b. I f nwm d m: 133 germs, acre: x 6 = 5 with moxhoom of 24.
(Using doetch and dlownsiom, dmb* a w1lbrna grid Ow has btu saw umber of inarseedm as dw
calmed number oroempltag polob »ccdod. Number the barandon points on the lagoon Still flu that data
recorded A each con be easily moWwd.)
14. Conduct siasdge survey sand .ward data on "Sludge Survey Data Sbar (Appeadix 2).
1. At the Ow of the sludge satvay, a bo .treasure the disunica from the Maximum Liquid Leval
to duc Present Ltqudd Level (maoatte at the lagoon gauge potek Co imw
L Determine the distance f mmt the Maxinsum Ligtdd level w tits Mnitrmm Liquid Level -2OLW
(use lWm m natgeme t plan or other lagoon aetxaads):
IL Catic4 to the dh ance fiam the pnesatt liquid scrim level to the Wmimum Liquid Level a: (Chc�
(Item J mhouip Item L assuaging the pi cm t liquid level is bdrrw the MLXimum Liquid Lev*.
L_ Record firma due Sludge 3urM Dm sheet the dtatattoe Rosa the pe+esent bVid surface level
to the lagoon bottom (avenge flit all the measurement poinb)- 22—Ile-01
M. Recwd f mm site Sludge Survey Dmta Shed tits distance f%m tho paesed liquid stir a lord
to die tap afore sludge toyer (average for ail the mess. points), (v .5 fleck
N. Record f am tine Sledge Sway Data Sheet the avenge thiel:tl = of the sludge layer.
O. Cakbldc the thickness of site existing Liquid ihVinent zone perm M -in— Rein Iq: y • �
(NoW WIN= O is lea than d &elk, a dtalge ntaaoral and ut.zlam pies ma9 be mialsw by
N.C. DWQ. See your apcchk petmk ercontact DWQ for.rm.e iabtmatian.)
P. Pmeced to the Sledge Volmee Wolf dmd if you denim to eslatlate sludge volvmc for a rectangular-
-shaped lagoon with uniform side slopes.
t;ampleted by, Date: • Q G�
Print Now Sige
14

• - I. 03/03/2007 17:03 9104232212 GALLBERRY CON PAGE 09
ARmadix 2. 8hde Sm"e' Data Sheet"
C
o�ONP�
et
Mir.=
MMN
r
"E��
�00
��
At��ti
lie!MM
!Ar
16
SO AAMP%ft afarCOMWT$wf" kxhw to &"dff afafODL
15

S. _t1
IRRIGATION SYSTEM DESIGN PARAMETERS
Landowner/Operator Name: Darrell Stocks, Sr.
Address: Hwy 904
Telephone: [phone]
Table 1 - Field Specifications
Approximate
Maximum
Useable Size
Field of Field
Number (acres) Soil Tvoe Slooe %
County: Columbus
Date: 5/29/2002
Revised 5/30/2007
Maximum
Maximum
Application
Application
per Irrigation
Rate
Cycle
Croo(s) (Inlhr)
(inches) Comments
1
9.49
NoB
<5
Bermuda
0.5
.5-1
Pulls 1-4
2
8.7
NoB/L
<5
Bermuda
0.5
.5-1
Pulls 5-8
3
2.92
Fo
<5
Bermuda
0.5
.5-11
Pull
4
11.81
Ly
<5
Row Crops
0.4
.5-1
Pulls 10,11,13
5
1.97
L INoA
<5
Row Crops
0.4
.5-1
Pull 15
6
5.84
Ly
<5
Row Crops
0.4
.5-1
Pulls 16,17
7
3.51
GoA
<5
Row Crops
0.4
.5-1
Pull 18
8
2.77
GoA
<5
Row Crops
0.4
.5-1
Pull 19
9
6.24
GoA
<5
Row Crops
0.4
.5-1
Pull 20
10
4.51
Ly
<5
Row Crops
0.4
.5-1
Pull 21
11
9.67
Ly
<5
Bermuda
0.5
.5-1
Pull22,23

f
5 A2
TABLE 2 - Travelling Irrigation Gun Settings
Make, Model and Type of Equipment: 3" Travellers
Field No. Travel Application TRAVEL LANE Wetted Nozzle Operating Operating
and Speed Rate Effective Effective Diameter Diameter Pressure Pressure Arc
Hydrant No. fVmin in/hr. Width ft. Len th ft feet Inches at Gun(psi) at reel si Pattern
F1,H1
1.95
0.45
235
310
270
1.08
60
95
330
F1,H2
1.95
0.45
200
300
270
1.08
60
95
330
F1,H3
2.34
0.62
180
320
270
1.08
60
95
220
F1,H4
1.95
0.45
234
200
270
1.08
60
95
330
F2.H5
2.34
0.62
170
540
270
1.08
60
95
220
F2,H6
2.34
0.62
170
330
270
1.08
60
95
220
F2,H7
2.34
0.62
170
300
270
1.08
60
95
220
F2,H8
2.34
0.62
171
400
270
1.08
60
95
220
F3,H9
1.95
0.45
270
315
270
1.08
60
95
330
F4,H10
2.34
0.62
140
415
270
1.08
60
95
220
F4,H11
1.95
0.45
200
730
270
1.08
60
95
330
F4,H13
1.95
0.45
235
815
270
1.08
60
95
330
F5,H15
3.69
0.76
135
480
270
1.08
60
95
180
F6,H16
1.95
0.45
270
310
270
1.08
60
95
330
F6,H17
1.95
0.45
270
320
270
1.08
60
95
330
F7,H18
1.95
0.45
270
410
270 1
1.08
60
95
330
F8,H19
1.95
0,45
270
290
270
1.08
60
95
330
F9,H2O
1.95
0.45
270
850
270
1.08
60
95
330
F10,H21
2.34
0.62
210.6
850
270
1.08
60
95
220
F11,22
2.34
0.62
208
980
270
1.08
60
95
220/330
F11.23
2.34
0.62
165
910
270
1.08
60
95
220

Sheet5
IRRIGATION SYSTEM DESIGNER
Name: Kraig Westerbeek
Company: Murphy -Brown, LLC
Address: PO Box 853 Warsaw, NC 28398
Phone: [phone]
Required Documentation.,
The following details of design and materials must accompany all Irrigation designs:
1. A scale drawing of the proposed irrigation system which includes hydrant locations. pipelines, thrust block locations and buffer areas where applicable.
2. Assumptions and computations for determining total dynamic head and horsepower requirements.
& Computations used to determine all mainline and lateral pipe sizes.
4. Souroes and/or calculations used for determining application rates.
5, Computations used to detairdne the etas of thrust blocks and illustrations of all thrust block configurations required In the system
e. Manufacturer's specifications for the Irrfgatlon pump, traveler and sprinkiar(s).
7. Manufacturer's spedfcations for the irrigation pipe and/or USDA-NRCS standard for IRRIGATION WATER CONVEYANCE.
& The information required by this form are the minimum requirements. It is the responsibility of the designer to consider all relevant factors at a pwficular site ai
address them as appropriate.
9. Irrigation pipes should not be Installed In lagoon or storage pond embankments willun t the approval of the designer.
NOTE: A buffer strip of 26 or wider must be maintained between the limits of the Irrigation system and all
perennial streams and surface waters per NC Statutes.

�r
S. A6
Narrative of Irrigation System Operation
This is a 'wetted acres' determination. Grower utilizes a 3" traveller, w11000' of hose for all pulls.
A 1.08" ring nozzle operated at 60psi gun pressure is to be used for all pulls
Pulls 22 and 23 are in a newly cleared field. SB515 setback criteria apply to this field: For the
purposes of this design, the setback includes a 75' setback from property lines only.
The acreage for these pulls is based on new and expanding sprayfield criteria.

Sheet?
CALCULATIONS
Spnjkler S, 2SMgM ons
Sprinkler Type: Nelson 150
Nozzle Size:
1.18 inches
Sprinkler Pressure:
60 psi
Flowrate(GPM):
182 gpm
Wetted Diameter:
270 feet *based on 90 % of manufacturers table
Lane Spacings
Desired Spacing (%):
70 %
Design Spadng(feet):
189 feet
Actual Spacing (feet):
200 feet
Actual Spacing (%):
74 %
ARR'jg�"
Application Rate =(96.3xFlowrate)1(3.1415x(.9xradius)squared)
Design App. Rate =
0.38 inthr
300 degree are =
0.45 in/hr
220 degree are =
0.62 inlhr
180 degree arc =
0.76 in/hr
Traveller Speed
Travel speed = 1.605 x Flowrate / Desired application amount x Lane Spacing
Desired app. (on.) =
0.75 inches
300 degree arc =
1.95 Mmin
220 degree arc =
2.34 ft/min
180 degree are =
3.89 ft/min
Mainline Velocit
Velocity = .408 x Flowrate / pipe diameter squared feet/sec.**
**For buried pipelines,
velocity should be below 5 feet per second
Pipe size:
inches
Velocity--
#Dlvro! ft/sec.
Page 1

Sheet4
TABLE 4 - Irrigation System Specifications
Traveling
Solid Set
I ' ation Gun
1 ation
Flow Rate of Sprinkler m
182
2peMing Pressure at Pump
95.0
Design Precipitation Rate rnmr
0.38
Hose Length feet
1000
XXXXXXXX
Typeof Speed Compensation
Mechanical
XXXXXXXX
Pump T TO, Engine 1
ine, Electric
Engine
Pump Power R uiremen#
35.0
TABLE 5 - Thrust Block SeRTications
THRUST BLOCK
LOCATION
AREA . ft.
90 degree bend
NA
Dead End
NA
Tee
NA
Gate Valve
NA
45 d ree bend
NA
Page 1

Sheet8
ACREAGE CALCULATIONS
Pull #
Width
Len th
Start End
Stop End
Pull Acres
Field #
Field Acres
1
235
310
0.61
0.5
2.78
1
9.49
2
200
300
0.56
0.45
2.39
3
180
320
6.36
0.45
2.13
4
234
200
0.61
0.5
2.18
5
170
540
0.39
0.25
2.75
2
8.70
6
170
330
0.39
0.25
1.93
7
170
300
0.39
0.25
1.81
8
171
400
0.39
0.25
2.21
9
270
315
0.53
0.44
2.92
3
2.92
10
140
415
0.35
0.25
1.93
4 i
11.80
11
200
730
0.56
0.45
4.36
13
235
815
0.61
0.5
5.51
15
135
480
0.26
0.22
1.97
5
1.97
16
270
310
0.53
0.44
2.89
6
5.84
17
270
320
0.53
0.44
2.95
18
270
410
0,531
0.44
3.51
7
3.51
19
2701
290
0.53
0.44
2.77
8
2.77
20
270
850
0.53
0.44
6.24
9
6.24
21
210.6
850
0.4
0
4.51
10
4.51
22
208
980
0.4
0.44
5.52
11
9.67
23
165
910
0.48
0.22
4.15
Page 1

(Multiple worksheets may be needed) HARD HOSE TRAVELER
IRRIGATION SYSTEM
Hard Hose Traveling Gun system
COMPUTATIONAL WORKSHEET
`�,c(�.(. �x�s ,elm c7
1. Farm number (ldenriflcation)r�. Field number (identification) �
2. Irrigation system designation Existing irrigation system New/expanded irrigation system
3. Number of travel lanes # Interior lanes # Exterior lanes feet] Length of pull(LI)
# Interior lanes # Exterior lanes [feet] Length of pull(L2)
# Interior lanes # Exterior lanes [feet] Length of ull(L.3)
4. Wetted diameter 220 [feet] from Field Data Worksheet *R, ''-r' Y-s-'7-6-1
S. Spacing Hydrant spacing [feet] (as a percentage of wetted diameter]
6. Hydrant layout Multiple hydrants Single Excessively spaced hydrants
7. Read the irrigated area per travel pull for the given wetted diameter from the appropriate table and column
based on pattern, spacing; and travel lane location.
Travel lane length (i,, Interior or _____ Exterior (lane/hydrant)
.4 0 (a) Acres start end of pull from Table "';Column � -
I ( (b) Acres middle portion of pull (U)
(Pull length'�50[feet) X Wetted width !a 6 [feet]) / 43,560
0a)
(c) Acres stop end of pull from Table Column
y 5 ` Total acres for travel lane length (LI) (Stun; a + b + c)
Travel lane length (L_) Interior or Mterior (lane/hydrant)
(a) Acres start end of pull from Table Column
(b) Acres middle portion of pull (L.2)
{Pull length [feet] X Wetted width __r___ [Feet)) 143,560
(c) Acres stop end of puull from Table Column
Total acres for travel lane length (L2) (Sum,: a + b + c)
Travel lane length (L. j Interior or Exterior (lane/hydrant)
(a) Acres start end of pull from Table ______ Column
(b) Acres middle portion of pull (I.3)
(Pull length_____ [feet] X Wetted width [feet]) / 43,560
(c) Acres stop end of pull from 1`able Column
Total acres for brave] lane length (L3) (Sum; a + b + c)
8. Multiply the tabulated irrigated acreage value per travel pull by the number of pulls of each
category in the held. Add all of these, and this is the total irrigated acreage for the field.
(a) Acres per travel lane length (LI)
(b) Acres per travel lane Iength (L2)
(c) Acres per travel lane length (L3)
X
# lanes =
Acres
X
# banes
Acres
X
# Lanes =
Acres
4.51 Total CNWM . wettable acres for field (Sum: Sa + 8b + 8c)
Wettable Acre Computational Worksheet Completed by - Date:
Signature of technical sped
ss

1
Sheeta ;
Z
ACREAGE CALCULATIONS
##
idth
Le h
a
o N
PuliAc
Field #
Field Acres
rPull
1
,235
310
0.61
0.5
2.78
1
9.49
2
200
300
0.56
O,45
2.39
3
180
320
0.36
0.45
2.13
4
234
200
0.61
0.5
2.18
5
170
540
0.39
0.25
2.75
2
8.70
6
170
330
0.39
0.25,-.
1.93
7
170
300
0.39
0,25
1.81
8
171
400
0.39
0.25
2.21
9
270
315
0.53
0.44
2.921
3
2.92
10
140
415
0.35
0.25
1.93
4
11.80
11
200
730
0.56
0.45
4.36
13
235
815
0.61
0.5
5.51
15
135
480
0.26
0.22
1.97
5
1.97
16
270
310
0.53
0.44
2.89
6
5.84
17
270
320
0.53
0.44
2.95
270
410
0.53
0.44
3.51
7
3.51
270
290
0.53
0.44
2.77
8
2.77
L20
270
850
0.531
0.44
6.24
9
6.24
53-241
53.24
m
�,V
Page 1

X"
"ON

ANIMAL FACILITY ANNUAL CERTIFICATION FORM
Certificate of Coverage or Permit Number /lI� PDI-Oo(, County C o(o."k k-�S, Year 200�5
Facility Name (as shown on Certificate of Coverage or Permit) Darrf L i Sf Ks Fe w yr
Operator in Charge for this Facility D�a V- rP 5-t-OC,S Certification #
Land application of animal waste as allowed by the above permit occurred during the past calendar year
YES NO. If NO, skip Part I and Part II and proceed to the certification. Also, if animal way
was generated but not land applied, please attach an explanation on how the animal waste was handled.
PartI : Facili Information:
1. Total number of application Fields 0 or Pulls please check the appropriate box) in the Certified Anim:
Waste Management Plan (CAWMP): �� _ Total Useable Acres approved in the CAWMI
2. Total number of Fields ❑ or Pulls lal&lease check the appropriate box). on which land application
occurred during the year: Total Acres on which waste was applied S3•�
3. Total pounds of Plant Available Nitrogen (PAN) applied during the year for all application sites:
'31L(2,55
4. Total pounds of Plant Available Nitrogen (PAN) allowed to be land applied annually by the CAWMP ar
the permit:
5. Estimated amount of total manure, litter and process wastewater sold or given to other persons and take
off site during the year _ 0 _ tons ❑ or gallons ❑ (please check the appropriate bo
5. Annual
average-,number of animals
bye at this facility during the previous year:
7. Largest and smallest number of animals by type at this facility at any one time during the previous year:
Largest_o _ _ -
Smallest 0 0
(These numbers are for informational purposes only since the only permit limit on the number of animal
at the facility is the annual average numbers)
8. Facility's Integrator if applicable: ITI
h - f --
Part H: Facg! Status:
IF THE ANSWER TO ANY STATEMENT BELOW IS "NO", PLEASE PROVIDE A WRITTEN
DESCRIPTION AS TO WHY THE FACILITY WAS NOT COMPLIANT, THE DATES OF ANY NON
COMPLIANCE, AND EXPLAIN CORRECTIVE ACTION TAKEN OR PROPOSED TO_BE TAKEN TO
BRING THIS FACILITY BACK INTO COMPLIANCE.
1. Only animal waste generated at this facility was applied to the permitted sites during ® Yes 111,
the past calendar year.
RECEIVED
AFACF 3-14-03 1 MAR 0 5 2004
%,,,1TEEi ()UkLITy SECT N
!�p41 �lc,:na.[t vOf�iD1�8RCB EN.

r
s-1 �
2. The facility was operated in such a way that there was no direct runoff of waste from Yes ❑ No
the facility (including the houses, lagoons/storage ponds and the application sites) during
the past calendar year.
3. There was no discharge of waste to surface water from this facility during the past 19 Yes ❑ No
calendar year.
4. There was no freeboard violation in any lagoons or storage ponds at this facility during Yes ❑ No
the past calendar year.
5. There was no PAN application to any fields or crops at this facility greater than the �K Yes ❑ No
levels specified in this facility's CAWMP during the past calendar year.
5. All land application equipment was calibrated at least once during the past calendar year. ❑ Yes ® No
7. Sludge accumulation in all lagoons did not exceed the volume for which the lagoon ❑ Yes IN No
was designedor reduce the lagoon's minimum treatment volume to less than the volume
for which the lagoon was designed.
8. A copy of the Annual Sludge Survey Form for this facility is attached to this Certification. ❑ Yes No
9. Annual soils analysis were performed on each field receiving animal waste -during the Yes ❑ No
past calendar year.
10. Soil pH was maintained as specified in the permit during the past calendar Year? f � Yes ❑ No
11. All required monitoring and reporting was performed in accordance with the facility's 9 Yes ❑ No
permit during the past calendar year.
12. All operations and maintenance requirements in the permit were complied with during IN Yes ❑ No
the past calendar year or, in the case of a deviation, prior authorization was received
from the Division of Water Quality.
13. Crops as specified in the CAWMP were maintained during the past calendar year on all % Yes ❑ No
sites receiving animal waste and the crops grown were removed in accordance with
the facility's permit.
14. All buffer requirements as specified on the permit and the CAWMP for this facility were NI Yes ❑ No
maintained during each application of animal waste during the past calendar year.
"I certify under penalty of law that this document and all attachments were prepared under my direction or
supervision in accordance with a system designed to assure that qualified personnel properly gather and
evaluate the information submitted. Based on my inquiry of the person or persons who manage the system, or
those persons directly responsible for gathering the information, the information submitted is, to the best of
my knowledge and belief, true, accurate, and complete. I am aware that there are significant penalties for
submitting false information, including the possibility of fines and imprisonment for knowing violations."
ame and 'I'Me (type or
Signature of Operator in Charge _. .
(if different from Permittee)
AFACF 3-14-03 2
Ca - fig- d :_
Date
Date

P.O. Box 759 �,-Wlvl
Q J r Rose Hill, NC 28458
Murphy -Brown LLC
910-289-2111
910-289-6478 Fax
April I2, 2004
Murphy -Brown, LLC
AM 5 =4
Rose Hill Division
Contract Growers
Dear ALICE FAYE STOCKS, ~
If your farm is currently covered by an NPDES permit, as a requirement of your permit, you
should have completed an annual certification form that summarized the environmental activities
on your farm for 2003. If you are not under an NPDES permit, ignore this letter. You will recall
that one of the questions on this annual certification form asked for your annual animal
population average. In a series of grower meetings that many of you attended, we committed to
provide you with your annual average inventories on or around the anniversary date of your
permit. Your annual average inventory, based on the information in our tracking system for
groups closed from 4-24-03 through 4-5-04 is as follows:
Facility Name Facility No. Permitted Head Actual Average
ALICE FAYE STOCKS 024-0006 4896 4590.6
If you did not provide the annual inventory average to DENR in your annual report, you should
forward this correspondence to them by the end of the month. They should be sent to the
following address:
NCDENR
Division of Water Quality
Permitting Unit
Attu. Keith Lorick
1617 Mail Service Center
Raleigh, NC 27626-1617
In addition, a copy of this correspondence should be kept with your environmental files.
If there are any questions or concerns regarding either the information contained in this letter, or
other environmental issues, please feel free to call me at (9 i 0) 293-5330.
Sincerely,
Kraig Westerbeek
Director of Environmental Compliance

O�0F VA TFRQG Michael F. Easley, Governor
A William G. Ross Jr., Secretary
r North Carolina Department of Environment and Natural Resources
_ Alan W. Klimek,-P.E. Director
Division of Water Quality
September 18, 2002
Darrell Stocks
12559 Swamp Fox Hwy-E
Tabor City, NC 28463
Subject: Land Application Equipment
Darrell Stocks Farm
Facility Number: 24-6
Columbus County --
Dear Mr. Stocks:
I met with you on September 9, 2002. During our meeting, you asked about land application equipment
that was similar to a linear system but could be attached to a reel in place of the usual gun cart. I told you
that I had seen a system of that description at a training that I had attended in 2001. I told you that I
would ask about the system and get back in touch with you with any information that I was able to obtain.
I first contacted Robert Evans with North Carolina State University who helped coordinate the training
that I had attended. Dr. Evans' telephone number is 919-515-6788. Dr. Evans said that Billy Hall was
the vendor who supplied the equipment, and Dr. Evans suggested that I contact Karl Shaffer also with
NCSU who has the land application equipment of this type at the training center. Mr. Shaffer's telephone
number is 919-515-7538. I contacted Mr. Shaffer who said that he had done some runs with the system
and at low pressure (12-16 psi) at the boom, it is very uniform and offers low drift. Mr. Shaffer said that
it knocks drift down by 60-80%. Mr. Shaffer said that there were multiple sprinkler options, the best of
which was yet to be determined. Mr. Shaffer also said that trash and hair is always an issue. Mr- Shaffer
said that Billy Hall of Billy's Irrigation Service at telephone number 910-285-9600 had donated a rig of
this type to the university. This letter does not endorse Mr. Hall, his company, his services, or his .
equipment. This letter is intended solely to relay information to you about land application equipment
about which you had asked.
I am pleased to have been able to gather this information for you, and I hope it is of assistance to you. If
you have any questions concerning this letter, please do not hesitate to contact me.
Sincerely,
l
Stonewall Mathis
Environmental Engineer I
Cc: John College, DSWC — WiRO
,DWQ Wil gtonFiles 24-6 -
S:IWQSIANEVIALSICOLUMBUS12002124-6letter
s�
N. C. Division of Water Quality 127 Cardinal Drive Extension [phone] Customer Service '
Wilmington Regional Office Wilmington, NC 28405 [phone] Fax [phone] NCDEW

Re: [Fwd: Lagoon problem - Legislative Inquiry]
0T-(p
Subject: Re: [Fwd. Lagoon problem - Legislative Inquiry]
Date: Tue, 10 Sep 2002 09:02:13 -0400
From: Stonewall Mathis <[e-mail]>
To: Dennis Ramsey <[e-mail]>
CC: Rick Shiver <[e-mail]>, John College <[e-mail]>
Dennis,
John and I visited these sites on 9/9/02. I saw no evidence of a discharge.
The odor complaint will be referred to Air Quality. John visited the sites on
9/7/02 and saw no evidence of a discharge.
Thanks,
Stoney
Dennis Ramsey wrote:
> Stony
> This is what Richard sent me and that I sent Rick. If you need more
> info to narrow down the facility that is of concern, please let me know.
> Thanks
> Dennis
> ------------------------------------------------------------------------
> Subject: Re: Lagoon problem - Legislative Inquiry
> Date: Wed, 04 Sep 2002 17:17:20 -0400
> From: Dennis Ramsey <[e-mail]>
> CC: Richard Rogers <Richard.Rogers&ncmail.net>,
> Laura DeVivo <[e-mail]>,
> Rick Shiver <[e-mail]>
> References: <3D74FE2A.BB2$[e-mail]>
>
> Rick
> Are you or your staff aware of any problems with Mr. Stocks facility near
> Tabor City?
> Thanks
> Dennis
>
> Richard Rogers wrote:
> > There are some citizens in Tabor City that complaining about odor from a
> > lagoon owned by a Mr. Darrell Stocks who lives at 12559 Swamp Fox Hwy.
> > in Tabor City or in the suburbs.
> >
> > The citizens have spoken to Mr. Stocks and asked him to put something in
> > the lagoon to control odor, but Mr. Stocks refuses saying that it is too
> > costly. There is also some allegations that the lagoon is above its
> > capacity and has overflowed.
> >
> > Can you provide me with some report of compliance in the past. I know
> > that DWQ can not take action regarding odor. Are there other problems
> > associated with this facility and does it warrant a visit?
> > Richard
Stonewall Mathis <Stonewall.Mathis2ncmail.net>
I of 2 9/10/2002 4: 10 PM

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
Darrell Stocks
Darrell Stocks Farm
12559 Swamp Fox Hwy-E
Tabor City NC 28463
Dear Darrell Stocks:
Alfflo.'W'A
IT 0
4 ae S �
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
December 30, 1999
Subject: Fertilizer Application Recordkeeping
Animal Waste Management System
Facility Number 24-6
Columbus County
This letter is being sent to clarify the recordkeeping requirement for Plant Available Nitrogen (PAN)
application on fields that are part of your Certified Animal Waste Management Plan.
In order to show that the agronomic loading rates for the crops being grown are not being exceeded, you
must keep records of all sources of nitrogen that are being added to these sites. This would include nitrogen
from all types of animal waste as well as municipal and industrial sludgestresiduals, and commercial fertilizers.
Beginning January 1, 2000, all nitrogen sources applied to land receiving animal waste are required to
be kept on the appropriate recordkeeping forms (i.e. IRR1, IRR2, DRY1, DRY2, DRY3, SLUR1, SLUR2,
SLD1, and SLD2) and maintained in the facility records for review. The Division of Water Quality (DWQ)
compliance inspectors and Division of Soil and Water operation reviewers will review all recordkeeping during
routine inspections. Facilities not documenting all sources of nitrogen application will be subject to an
appropriate enforcement action.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Ms. Sonya Avant of the
DWQ staff at [phone] ext. 571.
S
incere re,
r-
X 4�
Kerr T. Stevens, Director
Division of Water Quality
cc: Wilmington Regional Office
Columbus County Soil and Water Conservation District
Facility File
1617 Mail Service Center, Raleigh, North Carolina 27699-I617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recyeled IO% post -consumer paper

State of North Carolina
Department of Environment RECEIVED JUL 2 7
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
July 21, 1998
Darrell Stocks
Darrell Stocks Farm
12559 Swamp Fox Hwy-E
Tabor City NC 28463
I 1kT?W'J
i •
j9
NCDENR
NORTH CAROUNA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Application No. 240006
Additional Information Request
Darrell Stocks Farm
Animal Waste Operation
Columbus County
Dear Darrell Stocks:
The Non -Discharge Permitting Unit has completed a preliminary review of the subject application.
Additional information is required before we can continue our review. The following component was missing
from your Certified Animal Waste Management Plan:
1) The Waste Utilization Plan (WUP) lists soybeans, corn and wheat in a two-year rotation as
available crops for waste application. Residual nitrogen left over from the soybean crop in the
two-year rotation must be accounted for. Nitrogen application rates to the following crop are
required to be reduced by 15-30 lb. (dependent on soil type) to account for the residual nitrogen
left by the preceding soybean crop. Please revise your WUP to properly list all application rates
with residual nitrogen incorporated into your cropping scheme.
All revisions I amendments are required to be signed and dated by both the landowner and the Technical
Specialist before they are submitted for review. Please reference the subject permit application number when
providing the requested information. All information should be signed and submitted in duplicate to my attention
at the address below. The information requested by this letter, must be submitted on or before August 21, 1998 or
the Division will return your application as incomplete in accordance with 15A N.C.A.C. 2H .0200 and your
facility will be considered to be operating without a permit.
Please be advised that operation of the subject animal waste management system without a valid permit is
a violation of North Carolina General Statute 143-215.1 and will subject you to the enforcement authority of the
Environmental Management Commission.
If you have any questions regarding this request, please call me at [phone], extension 533.
Sincerer,
Katharine Keaton
Soil Scientist
Non -Discharge Permitting Unit
cc: Wilmington Regional Office, Water Quality
Permit File
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

State of North Carolina
Department of Environment
_ _and Natural Resources
Division of Water Quality SEQ 2 1199�
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary BY --
A. Preston Howard, Jr., P.E., Director
September 17, 1998
Darrell Stocks
Darrell Stocks Farm
12559 Swamp Fox Road Hwy-E
Tabor City NC 28463
N,CDENR'
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Certificate of Coverage No. AWS240006
Darrell Stocks Farm
Swine Waste Collection, Treatment,
Storage and Application System
Columbus County
Dear Darrell Stocks:
In accordance with your application received on June 8, 1998, we are forwarding this Certificate
of Coverage (COC) issued to Darrell Stocks, authorizing the operation 'of the subject animal waste
collection, treatment, storage and land application system in accordance with General Permit
AWG100000. This approval shall consist of the operation of this system including, but not limited to,
the management of animal waste from the Darrell Stocks Farm, located in Columbus County, with an.
animal capacity of no greater than 4896 Feeder to Finish and the application to land as specified in the
Certified Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations
as specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this -COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General
Permit or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS
143-215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This
request shall be made within 30 days of notification by the Division.
This COC is not automatically transferable. A name/ownership change application must be
submitted to the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the
right to apply for an individual non -discharge permit by contacting the engineer listed below for
P.O. Box 29535. Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

Certificate of Coverage AWS240006
Darrell Stocks Farm
Page 2
information on this process. Unless,such a request is made within 30 days, this COC shall be final and
binding.
The subject farm is located in the Wilmington Regional Office. The Regional Office Water
Quality Staff may be reached at [phone]. If you need additional information concerning this
COC or the General Permit, please contact JR Joshi at [phone] ext. 363.
Sincere ,
C
/, A. Preston Howard, Jr., P.E.
cc: (Certificate of Coverage only for all cc's)
Columbus County Health Department
Wilmington Regional Office, Water Quality Section
Columbus County Soil and Water Conservation District
Permit File -Central Files
Permit
File-NDPU

P.
t
.1 State of North Carolina R E C E I V E D
Department of Environment and Natural Resources WA1—LPQ11``1 iiYSECT,0N
Division of Water Quality JUN 81998
Non -Discharge Permit Application Form
(THIS FORM MAYBE PHOTOCOPIED FOR USE AS AN ORIGINAL) nE, _
Genera! Permit - Existing Liquid Animal Waste Gperatrons ull Permitting
The following questions have been completed utilizing information on file with the Division. ,Please
review the information for completeness and make any corrections which are appropriate. If a
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
I. GENERAL INFORMATION:
.l . I Facility Name: Darrell Stocks Farm
1.2 Print Land Owner's name: Darrell Stocks ,
City. State: "Tabor City NC - zip: 29463
Telephone Number (include area code): 653-9386
1.4 County where facility is located: Columbus
L5 Facility Location (Directions from nearest major highway_ Please include SR numbers for state roads_ Please include a
copy of a county road map with the location of the farm identified): On Hwy 904 in Dulah near intersection with SA I 109.
Farm road is on the north side of Hwv 904.
1.6 Print Farm Manager's name (if different from Land Owner):
1.7 Lessee's / Integrator's name (if applicable; please circle which type is listed): Murphy Familv Farris
1.8 Date Facility Originally Began Operation: 01/01/92
1.9 Date(s) of Facility Expansion(s) (if applicable):
2. OPERATION INFORMATION:
2.1 Facility No.: �24_ (county number); _$_ (facility number).
2.2 Operation Description: Swine operation
Feeder to Finish
4896- Certified Design Capacity
Is the above information correct? yes; no. If no, correct below using the design capacity of the facility
The "No. of Animals" should'be the maximum number for which the waste management structures were designed. -
TV
Pe of Swine
Wean to Feeder
Feeder to Finish
Farrow to Wean (4 sow)
Farrow to Feeder (# sow)
Harrow to Finish (# saw)
No. of Animals Tv e of Poultry No. of Animals
Other Type of Livestock on the faun:
Layer
Non -Layer
Turkev
Type of Cattle No. of Animals
Dairy
Beef
a
No. of Animals:
FORM: AWO-G--E 1/28n93 Page I of 4 24 - 6

3.
2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): 35.1 ; Required Acreage (as listed in the AWMP): 29.3
2.4 Are subsurface drains present within 100' of any of the application fields? YES or (9-
(please circle one)
2.5 Are subsurface drains present in the vicinity or under the lagoon(s)? YES or(please circle one)
2.6 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, NRCS Standards, etc.) (Swine Only)
ES or NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited? 9 - Z % _ 9 / -
What was the date that this facility's land application areas were sited? 7- f 5-
REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
3.2 Two copies of general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit
application for animal waste operations.
The CAWMP must include the following components:
3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application.
3.3.4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
3.3.6 -rhe Realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application field.
3.3.8 'rhe waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.3.10 A site schematic.
3.3.11 Emergency Action Plan.
3.3.12 Insect Control Checklist with chosen best management practices noted.
3.3.13 Odor Control -Checklist with chosen best management practices noted.
3.3.14 Mortality Control Checklist with the selected method noted.
3.3.15 La!ucionlstonme Pond capacity documentation (design, calculations, etc.)
If your CAWMP includes components not shown on this list, such as an irrigation design,
or site evaluation, please include the additional components with your submittal.
Applicants Initials
Rwas
WIN
FORM: AWO-G-E 1 /28/98 Page 2 of 4 24 - 6

M
Facility Number. 24 - 6
Facility Name: Darrell Stocks Farm
4. APPLICANT'S CERTIFICATION:
1, All r- r-c� J/ S-,-, l, -JL<- (Land Ownees name listed in question 1.2), attest that
this application for 3foo k. F-0 r- ri-I (Facility name listed in question 1.1)
has been reviewed by me and is accurate drid complete to thd best of my knowledge. I understand that if all required parts of this
application are n t completed and that if all required su porting infomiation and attachments are not included, this application
package will b med to me i omple
Signature U Date _ �; _ 9 g
5. MANAGER'S CERTIFICATION: (complete only if different from the Land Owner)
1,
(Manager's name listed in question 1.6), attest that this
application for (Facility name listed in question 1.1)
has been reviewed y the and is accurate and complete tot a best of my knowledge. I un erstand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned as incomplete.
Signature
Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
FORM: AWO-G-E 1/28/98 Page 3 of 4 24 - 6

DBIS[ON OF WATER QUALITY REGIONAL OFFICES (1/98)
Asheville Rczional R'Q Supervisor
59 V+ocd`in Place
Ashevilie. NC 28801
[phone]
Fax (%04) 251-6452
Avery
Macon
Buncombe
Madison
Burke
McDowell
Caldwell
Mitchell
Cherokee
Poll:
Clad-
Rutherford
Graham
Swain
l:a •1• god
Tr2nsvlvania
Henderson
Yancev
Jackson
Favettevilie Regional WQ Supmisor
WachoLia Buii L--ic. Suite 714
Fa,ene%ille. NC 2S:01
(9i0)4S6-1,'-1
Fax (91 Gl-t56-T70 7
Washington Regional WQ Supmisor
943 Washington Square Mall
Washington, NC 27889
[phone]
Fax [phone]
Beaufort Jones
Bertie
Lenoir
Camden
Martin
Chow•an
Pamlico
Craven
Pasquotank
Curritucit
Perquirnans
Dare
Pitt
Gates
Tyrell
Greene
Washington
Hertford
Wayne
Hyde
Mooresville Regional WQ Supervisor
919 North Main Street
Mooresville, NC 28115
[phone]
Fax [phone]
Raleigh Regional WQ Supervisor
3800 Barrett Dr.
Raleigh, NC 27611
[phone]
Fax [phone]
Chatham
Nash
Durham
Northampton
£dsecombe
Orange
Franklin
Person
Granville
Vance
Halifax
Wake
Johnston
Warren
Lee
Wilson
Wilminmon Rezion.'WQ Supervisor
127 Cardinal Drive Extension
Wilmington. NC 28405-3845
[phone]
Fax [phone]
Anson
Moore
Alexander
Lincoln
Brunswick New Hanover
Bladen
Ric;irtond
Cabarrus
Mecklenburg
Carteret Onslow-
Cu:nbe. i_ ;d
Robeson
Catawba
Rowan
Columbus Pender
Har^a:t
Sampson
Cleveland
Stanly-
Duplin
Hole
Scotiand
Gaston
Union
Montgar ne ,
iredell
%Vinstcn-Saiem.. Regional WQ Supervisor
585 WaLz:3te",r, Sheet
W lnstor- \C -, j 1 l] i
[phone]
Fax (91GO 77i-46;1
Alamance
Rockins!hain
A!1--- ",an
Ra:,do1-h
Ashe
Stokes
Cas,, ell
Surn-
Datiidson
Wzltau:a
Davie
Rakes
Fors-zh
Yadkc
Guilford
FORM: A«'O-G-E 1J28/98 Pace 4 of 4

—.44 1

Producer: .r t-&I ( ') fo cK s 5r.
Location: Au)y `10'i C -!—. L s G
Telephone: ry 1 o(. 5 3 13 1 (�
Type Operation:
Number of'Animals: LTM
(Design Capacity)
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface and/or groundwater. The plant nutrients in the animal waste should
be used to reduce the amount of commercial fertilizer required for the crops in the fields
where the waste is to be applied. This waste utilization plan uses nitrogen as the limiting
nutrient. Waste should be analyzed before each application cycle. Annual soil tests are
strongly encouraged so that all plant nutrients can be balanced for realistic yields of the
crop to be grown.
Several factors are important in implementing your waste utilization plan in order to
maximize the fertilizer value of the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply more nitrogen than the crop
can utilize. Soil types are important as they have different infiltration rates, leaching
potentials, cation exchange capacities, and available water holding capacities.. Normally
waste shall not be applied to land eroding at greater than 5 tons per acre per year. With
special precautions, waste may be applied to land eroding at up to 10 tons per acre per
year. Do not apply waste on saturated soils, when it is raining, or when the surface is
frozen. Either of these conditions may result in runoff to surface waters which is not
allowed under DEM regulations. Wind conditions should also be considered to avoid drift _
and downwind odor problems. To maximize the value of nutrients for crop production
and to reduce the potential for pollution, the waste should be applied to a growing crop or
applied to bare ground not more than 30 days prior to planting_ injecting the waste or
disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. Acreage requirements should be based on the waste analysis
report from your waste management facility. Attached you will find information on
proper sampling techniques, preparation, and transfer of waste samples to the lab for
analysis_
This waste utilization plan, if carried out, meets the requirements for compliance with 15A
NCAC 2H.0217 adopted by the Environmental Management Commission.

u''sI�.z v PLAN
Amount of Waste Produced Per Year(gallons, ft3, toms, etc.
`189 L animals X L • `140 (� r waste/animal/year = oa �° waste/year.
Amount of Plant Available Nitrogen (PAN) Produced Per Year
415kanimals X�3•3lbs. PAN/animal/year -1'►.!?!Li lbs. PAN/year. (PAN from N. C. Tech.
Guide Std. 633)
Applying the above amount of waste is a big Job. You should plan time and have
appropriate equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on the crop to be grown
and surface application:
Table 1: ACRES OWNED BY PRODUCER
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
# No. Tvne Per Ac. * Utilized Annheation
T6,613 lD
1
da
rw+ f4
3 a
I'!.
Ks,111.6
T 5��
Z
�-
.�►� f
�'15
�3R.��
���-oak
t, OCI,
TL O
14
300
.1. b
-1 Iwo
/AOLr-C6- c
r(-5oH
10
L
8..., H
a-1
oJ .
-R.5011
1 1
nlb A
ear,.
5
.a
1��1 i
Marcl.-Oc �.
T65o
5
�.
rr,. 0.�H
eRta
d1
!
F.d
abG.I�
+
'ra
S.nakI em, rw.J,%
i
a°i.3
d9
:5C,
t r,
Total
* This N is from animal waste only. If nutrients from other sources such as conunercial
fertilizer are applied, they must be accounted far. N roust be based on realistic
ypectation.
NOTE. ? be applicator is cautioned that P and K may be over applied while meeting the N
requirements. Beginning in 1996 the Coastal Zone Management Act will require farmers in
some eastern counties of North Carolina to have a nutrient management plan float addresses
all nutrients. This plan only addresses Nitrogen.
L
2

RECEIVED
U�i PT
i .._.:?•F;.'`k,.`�i'a`.�'E+'-C.(lam! /�
V
JUN 81998
Table 2- ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowner mast be attached)
(Required only if operator does not own
adequate land [see Required Specification 21)
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
* See fontnate for Table 1.
Totals from above Tables
Acres Lbs. N
Utilized
Table 1
Table 2
Total
Amount of N
Surplus or
efi
q.3
l! �a1
Produced
1
to O
NOTE: The Waste Utilization Plan must contain provisions for periodic land Wrrco-
application of sludge at agronomic rates. The sludge will be nutrient rich and will �7
require precautionary measures to prevent over application of nutrien&s or other
elements
0

rru
.- ... :... ..: ....-.. .
See attached map showing the fields to be used for the utilization of waste water.
Application of Waste by Irrigation
Field Soil Type Crop Application Application
No. Rate WHO Amount (In.)
1111
Q rrvwAm
- .5
- S
1! 06
- 5
•
3. 19
c�--
{B�-rrnrn30%
Ile\�
• J
r
THIS TABLE IS N(Yr NEEDED IT WASTE IS NOT BEINGAPPLIED BY HWGATION HOWEVER A SIMILAR T'ABIJi W Q1.
BE NEEDED FOR DRY I JT'rT--R OR SLURRY.
Your facility is designed for I'M days of temporary storage and the temporary storage
must be removed on the average of once every(o MONTHS. In no instance should
the volume of waste being stored in your structure exceed Elevation JetsEo c-
Call the local Natural Resources Conservation Service (formerly Soil Conservation
Service) or Soil and Water Conservation District office after you receive the waste
analysis report for assistance in determining the amount per acre to apply and the proper
application rate prior to applying the waste.
r�
y
4

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
i. Animal waste shall not reach swrfarR waters; of the state by
runoff, drift, manmade conveyances, direct application, or
direct dioc:hnrge during operatinn or land application. Any
discharge of waste which reaches surface water is prohibit- .
?. kere must be documentation in the design folder ..hat the
producer wither owns or has an agreement for use of adequate
land on which zo properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
pr.^.; Ne a copy of an agresma t with: a laniawner who is within a
reasonable proximity, allowing him/her the use of the land for
waste. application. It is the responsibility of the owner of the
facility to secure an-updAteof the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that.restrict
the rate of application for other nutrients.
4. knimal waste shall be applied to land eroding less that: 5 tons
per acre per year, Waste may be applied to land that is eroding
at 5 or more torts, but less than IQ tons per acre per year
providing grass filter strips are installed where rur_oii leaves
the field. (See FOTG Standard 393 -Filter Strip)
5. Odors can be reduced by injecting the waste or disking after'
waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
6. when animal waste is to be applied on acres subject t:
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, -the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
and Climate in Forth Carolina" fot guidance.)
7. Liquid waste shall be applied at rates nct to exceed the soil
infiltration rate such that runoff does not occur offsU e or to
.surface waters and- in a method which does not cruse drift horn
:he site during application:. No ponding should occur it order
vo control odor or flies.
8. Animal waste shall not be applied to saturated soils, during
r niv all events, or when nh? 5urface is frozen,
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is riot covered with waste to a depth that
would inhibit growth. The pQnen4ial for salt damage from animal
waste should also be considered.
Page: 10

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
10. Waste nutrients shall not be applied in fall cr winter for
spring planted crops on s _ i!G with a high potential for
leaching waste nutrient Inating rates on these_ oils. should be
held to a minimum and a sui=ahleJwinter cover crop planned to
take up released nutrients. waste shall not he applied more
than 30 days prior to planting of the crop or Scrages breaking
dormancy.
11. Any new spline facility sit_d can or after Octcher 1, 1995 .hall
comply with the following .he outer perimeter of ?_he land area
onto which waste is applied from a lagoon that in a component of
a swine farm shall be at least 5o feet from any residential
property -boundary and7from any perennial stream or river (other
than an irrigation ditch or canal.. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to
Feeds.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste.shall be app;i.ed in a manner not to reach other property
and public right-of-wayti.
15. Animal wasts shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by :ever -spraying.
Animal waste may be applied to prior conversed cropland provided
they have been approved as a land; application sitebya
"technical. specialist". Animal waste shall not be applied on
grassed waterways that discharges directly inton water courses,
and on !other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
tie site.
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, e _ s. , shall not be discharged into the
animal waste management syst m.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to .
protect the vegetation. Vegetation such as tress, shrubs, an'i
other woody species, etc., art limited to areas where considered
appropriate. Lagoon areas should be kept mower. and accessible.
Berms and structures should be inspected ragulvriy for evidence
of erosion, leakage or discharge.
Page: 11

WASTE UTILIZATION PECAN
REQU—TRED SPECIFICATIONS
18. if animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the
pu ;slbility of an illegal discharge, pollur.ion and erosion.
19. Waste handling Stru lturea , piping, pumps, reels, nr.c _ , -c,hn>> 1 r3
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can, be used in a rc.tation that includes vegetables
and other drops for direct human consumption. However, if
animal' waste is used -on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to Mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22. Waste shall be tested within 60 days of utilization and soil
shall be'tested _at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element. Zinc_ and c000er levels in the soils shall be
monitored and alternative crop 9itas shall be 11oCd when rhea
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept_fpr five" year,. Poultry dry
waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be
maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North
Carolina requlations.
Page; 12

• -�� ) -- W��.i�'k .i1•. ��� 1/.� .SaiA��`f .�y L'� 2 a!
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: D.,vre. k 5toc-%S ,
Owner/Manager Agreement
I (we) understand and will follow and implement the specification and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. I (we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new facilities will require a new
certification to be submitted to the Division of Environment Management (DEM) before
the new animals are stocked. I (we) also understand that there must be no discharge of
animal waste from this system to surface wasters of the state from a storm event less
severe than the 25-year, 24-hour storm. The approved plan will be filed on -site at the
farm office and at the office of the local Soil and Water Conservation District and will be
available for review by DEM upon request.
Name of Facility Owner: p Ck<- r e-11
(Please print --- —_ _
Signature: Date:
Name of Manager(If different from owner):
Signature:
Date:
Name of Technicdl Specialist: (Please print)rG
Affiliation:
Address (Agency):-759
n1 N-r Ht-A1, nV""C a-411��'
5

• • - --F- ''f}nn
i
nnn
• �F�IGiE�n• .�
Tc3L' 1: ACRES OWLNIED B ' kfieER
T_ac--, Feld Sou Crop Lbs. Acres Lbs.ti bfen Of
r- No. *rya Per Ac_ Li �__�� lstniir.14
i7oSo'-f
f A a
11- I ;,�
I a
! �. 7
1'. 3�. 5 1 A
,1 -J 1
I :)
1 Isn e
1 fac;
1 4:I
I Ias i1
_ t
f I IL!
1 �
f
f
! -a-1 I
Yo
cti H
f
! cAl r,-,
!1,25f
-7
13 I
e
I4
1 i-O+A f I
I a C>
I ads+
I 14
1 L4 - I Niz« . !
1 +. 3
r
Tb y
f
I
13.0
I asl
7
!
I 1 A„ 1
o
I
! ,,
!
f
t,
M-c'n LiI
I I f
r')S
1G,1LbWke,hf
q to
I 'c, Sa 0
l sZ
1 G A I C,. r , !
F A A
I a.cr
Li T 6 I A
I 50 9 cl I LI I. bz I f I b l i Ke -A,
I -a 4I I L I tJWe.%4 I ! .- I
f rAll, 4L"
C r,s
I TL61 I i 1 X A !
I I 1 ► ! 1 I I
i 1 1 I 1 f I I 1
C��Is Or -M J i C,• 1;,. tea
<A-&1
f I I I I ►
1 ! I f I ! I 1
1 f I I i I 1 I
I I I I I 1 I
I I I f I I f !
I i I 1 I I i f
I 1 I I ! f I I I
f ( I 1 { ! I
f I I f i I I
f ! I I ! I I !
I I I I f I I 1
! •.. I I I I I I I
f I 1 I I I I
f 1 I I i I I
f I 1 I I I I I
1 l I I I I I
1 f i f i I 1 I
I
t -�

4L
. tj -4
1017
j
kh'
I . f . . .......
fr
-4v k7'e, 4�r
liz In 7-1 71
00
dMa
��_. - }. ��
Ir
U4,
t�ylii • tft
of
so
0 Of
. le
ell or 4.
%
%
Ah
to Of
d 10
C%
``'•��rN.'• •x�i :a•Qy ,"�"!•/ �1 ��ir•`!_".' ' ^ .`�j��� � -- ./�31. Jy% ``�..r I}w�;r1
OR
CP
-401 -4

- • � `r _' > t- r'.:+i '• . '� if - �/ i yy sir`' •� ¢ x,. •�•.. I . ' _ '� `
GGOA
OA'
�r
x 1 .• j'a:�� Go
GoA
J,'�e r,'�.ir ✓�.y
Ly AuB NOA L 44
vlaq
d R f� ;� k,% GOA NOA
✓ rai' r. y Fa y GOA
A.13 R L Nqq
s _ sl y
JCr6
- GCA Ec GoA Ly GoA
`Sukl \ p.: +�• �t ..- '" y r Ly r/ r GoA •` S 8eGOA F
6
6 �-yi'Y�;�a':! E s - •--�:t^r 1. - SS iYe f CA y`�,Yi ./• r Exri
via
]y�\,�W PC
Et �J + C: AUB Fo y '1 I`:..���
• •-� } Wa6 �-..
waB y .
N.
t 'LnB y y co
�C�7By
W F ! EC WaB Ec
Ec` `•t Ta'k % ,may'
"r Ec LnB Js
LnB
Ec X' ILY'
Ec- WaB
M
U. �. Ec',M1 t .:ice ' \ - °'tl• �: -
"-'sc+lllSu a. Nob ° tias -� gswr y "" • ,t., 4..rr, r
Ec tn8}, Ln6 Ec : St a IT
qu
�� GoA pa - .� .• G.h^ _ � � -,� �r•.,. 1 �3'.F,`F"'"' ]f_ M �a� �r -
Ec _ wa Mk LY 6:V1�! _n ', �v.a F;' •' !T-, frc..r_
Me
•:_ • b � T :, C F _ {a0A - -w GfBr c � � •- X;s � _ �
NOA GOA �'� NOA-•if'Citj t -fief: ^ . �• .t'��`"t4 •i
Goa GoA = s'. Ly
Ra-
s T a
L
Na r Ly
Fo
s NOB
�' GoA •"`+�. Fo o :-Wa •r• fir-., .
wMe Ra *"
tn
11
GoA
Cr8 Na_rMC NOB Ly
Ra �. .' fa ,Utl
C:i�'` 0r • Fo
}. �_ GOA GOA
Na#F t 4f^ Y r t. B AMu •,
Fo
t. - Ly � • NoA Fo -
i , ,r iy•
Gt
GoA �4•.' t4wAr^

C
F
�}�+ *r J ��� � '•` �., r, �ram. $ 'i�' �
ji� r 1 7
fs—
try`, � � A %) ♦ + �'
,
y ,
,
r A'
♦ r i t�
aY * t P = 1 A
�? 'a-•'� - n�� 'mow"`"��� � �` ,5�� '_''��� � �
A
a
n. - ge r r. a w x :'"'d " l a*,;y - ":"��, 1�..-, '� `�J � j�xwa ., ✓ ,•'=_ �
� y- w �x fit. ,.d,L ;_. •l Jl y.y » • •(",. � ¢'rz 6`�y� ''�a�yt R wd.

3,. �sr
�F: 4
r
.mil .�` _- �
� � `' Y v '
t-' ��
` jar.<. _ .>, � ���
�. // r ��
.Ji
'J. ''.
'�,,3. i i. .+
`,' �`+` .
J

S W I N E L A G O O N D E S I G N
County:Date
Operator:�������� .sr-dc/ts _�o��r,;;:�s
Distance to nearest residence (other than owner): / c o e feet f
1. STEADY STATE LIVE WEIGHT
saws
(farrow to finish)
x 140
lbs.
= Ibs
sows
(farrow to feeder)
x 522
lbs.
= lbs
3� ahead
(finishing only)
x 135
lbs.
lbs
sows
(farrow to wean)
x 433
lbs.
lbs
.
head
(wean to feeder)
x 30
lbs.
= Ibs
TOTAL STEADY STATE LIVE WEIGHT (SSLW) 9.s 7z v lbs -
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = SSLW x Treatment Volume(CF)/lb. SSLW
Treatment Volume(CF)/Ib. SSLW= _ l o CF/lb• SSLW
Volume -7.2o Cubic feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = — cubic feet

4.
TOTAL DESIGN VOLUME _. ,so,�_,., _ �3nw �a -'1-' p�u
/o/7gc r7S,,=/o25'36 F%ry
Inside top length feet ; Inside top width feet
Top of dike at elevation feet
Freeboard / s feet ; Side slopes z•3— : 1 (Inside lagoon)
Total design lagoon liquid level at elevation 9 o feet
Bottom of lagoon elevation 39.s feet -
Seasonal high water table elevation //-f- 3 feet
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH
z9/ /sue
a.s a.s a,s a.s 3�3� /s/ /-.r
AREA OF TOP
LENGTH * WIDTH =
(AREA OF TOP)
AREA OF BOTTOM
LENGTH * WIDTH =
(AREA OF BOTTOM)
AREA OF MIDSECTION 711 t
LENGTH WIDTH * 4
�.S x 17S•63 x9_r
/,Z�•2 J� �J/•C� = /fz7:.:=-4'•371"(FfITLFio�111U5CLll�li-;�"�il
CU. FT. = [AREA TOP + (4*AREA MIDSECTION) + AREA BOTTOM] * DEPTH/6
VOLUME OF LAGOON AT TOTAL DESIGN LIQUID LEVEL 7`se®I%o CU. FT.
�/o Gc..r f/S /-�Si', -.: TF✓ L,t ,/�.•" /h,0-Si`a iicN o 7 S/': 'FaE l7c.i, T
Y'=•-.w .: T_-rT n. ,�-� .., „.C• t�/-).: r' ,P.-74 .-i, �a :JLu-.I oJ.!/=/G i>,: -

F,
5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
= /az�quare feet
Buildings (roof and lot water)
Length Width =
square feet
TOTAL DA- square feet
Design temporary storage period to be
5A. Volume of waste produced
/8o days.
Approximate daily production of manure in CF/LB SSLW 0.00136
Volume = 9S- 72o Lbs. SSLW * CF of Waste/Lb./Day i 8Q days
Volume = cubic feet

5B. Volume of wash water PAGE 4
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume = — gallons/day * days storage/7.48 gallons
per CF
Volume = -- cubic feet
'5C. Volume of rainfall in excess of- evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
.L90 days excess rainfall = 7 o inches
/o 2 S 36 ,OT '
Volume = 7 in * DA / 12 inches per foot
Volume = s-9 /3 cubic feet
5D. Volume of 25 year - 24 hour storm
Volume = 7. S inches / 12 inches per foot * DA
Volume = 611, cubic feet
TOTAL REQUIRE➢ TEMPORARY STORAGE
V5A.
cubic feet
5B.
— cubic feet
,i5C.
s9:F / ? cubic feet
,/5D.
6j-ff cubic feet
TOTAL cubic feet

PAGE 5
•6. SUMMARY
Total required volume , ,Z.,1eG 92a cubic feet
6 all
Fly-$
Total design volume avail. 75&&'_o cubic feet
Min, req. treatment volume plus sludge accumulation #95- 7ae, cubic feet
At elev. feet ; Volume i54t9S7a� cubic feet (end pumping)
Total design volume less 25yr-E4hr storm is C 2K,��Scubic feet
At elev.. -;g8, 3 feet ; Volume is 67&-,,:7s_rcubic feet (start pumping)
Seasonalhigh water table elevation �[S3 feet
7. DESIGNED BY: APPROVED BY:
f
DATE:.
t2.i-assr
DATE: i > - v- 9

OPERATION AND MAINTENANCE PLAN
------------------------------
This lagoon is designed for waste treatment with minimum odor
control. The time required for the planned fluid level to be
reached may vary due to soil conditions,flush ing operations, and
the amount of fresh water added to the system.
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent runoff from the field or damage
to crops.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre -
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see Attachment B)
before land application.
3. Begin pump -out of the lagoon when fluid level reaches eleva-
tion 5�8.3- as marked by permanent markers. Stop pump -out when
the fluid level reaches elevation :1�49Zey ' or before fluid depth is
less than 6 feet deep (this prevents the loss of favorable
bacteria) .
4. The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended maximum application rate is 0.4
inch per hour.
5. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
outlets.
S. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.

SEEDING RECOMMENDATIONS
AREA TO BE SEEDED: 2• O ACRES
USE THE SEED MIXTURE INDICATED:
LBS. FESCUE GRASS a 60 LBS./ACRE
(BEST SUITED ON CLAYEY OR WET SOIL CONDITIONS)
SEEDING DATES: SEPTEMBER 15 TO NOVEMBER 30
LBS. 'PENSACOLA' BAHIA GRASS a 60 LBS./ACRE
(SEE FOOTNOTE NO. 1)
SEEDING DATES: MARCH 15 TO JUNE 30
i LBS. HULLED BERMUDA GRASS @ 8 LBS./AC.
(SUITED FOR MOST SOIL CONDITIONS)
SEEDING DATES: APRIL 1 TO JULY 31
�G LBS. RYE GRAIN Z 30 LBS./ACRE (NURSERY FOR FESCUE)
v LBS. RYE GRASS a 40 LBS./ACRE (TEMPORARY VEGETATION)
SEEDING DATES: DECEMBER 1 TO MARCH 30
LBS.
APPLY THE FOLLOWING:
a c LBS. OF 10-10-10 FERTILIZER (1000 LBS./ACRE)
TONS OF DOLOMITIC LIME (2 TONS/ACRE)
ao o BALES OF SMALL GRAIN STRAW (100 BALES/ACRE)
ALL SURFACE DRAINS SHOULD BE INSTALLED PRIOR TO SEEDING. SHAPE
ALL DISTURBED AREA IMMEDIATELY AFTER EARTH MOVING IS COMPLETED.
APPLY LIME AND FERTILIZER THEN DISK TO PREPARE A 3 TO 4 INCH
SMOOTH SEEDBED. APPLY SEED AND FIRM SEEDBED WITH A CULTIPACKER
OR SIMILAR EQUIPMENT. APPLY MULCH AND SECURE WITH A MULCH
ANCHORING TOOL OR NETTING.
1. PENSACOLA BAHIACRASS IS SLOWER TO ESTABLISH THAN COMMON
BERMUDA GRASS. WHEN USING BAHIA, IT IS RECOMMENDED THAT 8
LBS./ACRE OF COMMON BERMUDA BE INCLUDED TO PROVIDE COVER
UNTIL BAHIAGRASS IS ESTABLISHED.

'SPECIFICATIONS FOR CONSTRUCTION OF WASTE TREATMENT LAGOONS
Clearing:
All trees and brush shall be removed from the construction area
before any excavating or fill is started. Stumps will be removed
within the area of the foundation of the embankment and fill areas
and all excavated areas. All stumps and roots exceeding one (1)
inch in diameter shall be removed to a minimum depth of one (1)
foot. Satisfactory disposition will be made of all debris. The
foundation area shall be loosened thoroughly before placement of
embankment material.
Cut-off Trench:
A cut-off trench (when specified) shall be irstalled as shown in
the plans. A1,, I'
Construction:
-------------
Construction of excavated and earthfill areas shall be performed to
the neat lines and grades as planned. Deviations from this will
require prior approval of the SCS. Earthfill shall not be placed
in standing water and reasonable compaction of the fills shall be
performed by the construction equipment or sheeps-foot roller during
placement. The embankment of the lagoon shall be installed using
the more impervious materials. Construction of fill heights shall
include ten (10) percent for settlement. To protect against seepage,
when areas of unsuitable material are encountered, they will need to
be excavated a minimum of one (1) foot below grade and backfilled and
compacted with a suitable material (ie-CL,SC,CH). Refer to the soils
investigation information in the plans for special considerations.
Precautions should be taken during construction to prevent excessive
erosion and sedimentation.
.S'i .t/ a y CS P, h , n, j�, rl fl Gas' �'A—Cv.� . ✓ T,r� �t,•v .�
rA� o v �% �L.or. , c..� Ei ,� . rT��,s' �' �- L',� TH.l. ,r .�' �• rJ Cc o./
Vegetation:
G AIA Zraa7 bvs Z ✓.v0y c .CA �� i .?c'� .,1 w �, i ` - f I= i :.% y'. ✓./� f j
x
All exposed embankment and other bare constructed areas shall be
seeded to the planned type of vegetation as soon as possible after
construction.
SxB J-0"4 /.-/ c 57PZ45zr,

U. S. Department of Agriculture NC-ENG-34
Soil Conservation Service September 1980
File Code: 210
� AV.lJ
HAZARD CLASSIFICATION DATA SHEET FOR OAMS-
Landowner l7gP,P /- -57oc lr-S County G'o�o rr1z S
Community or Group No. Conservation Plan No.
Estimated Depth of Water to Top of Dam_,:J_Ft. Length of Flood Pool 7o o Ft.
Date of Field Hazard Investigation 9--i 7- 9/
Evaluation by reach of flood plain downstream to the point of estimated minor effect
from sudden dam failure.
Est. Elev.:Est. evat-on
Kind of :Improvements: of Breach
Reach: Length: Width: Slope: Land Use Improvements Above :Floodwater Above
Flood Plain: Flood Plain
Ft.. Ft. Ft. Ft.
1
2
3
Describe potential for loss of life and damage to existing or probable future downstream
improvements from a sudden breach My vg _ isoo -,7
LAG>o / X-,7 T GPirr.-- 77- 32f,4114"- -
Hazard Classification of Dam � b, c) (see NEM-Part 520.21
� 9 C.s�•o/
—Bam•Classification (I, II, III, IV V)
B Dy G E Date /- /7-
y name) — - / (t1t e
Concurred By Date
name title
NOTE: 1. Instructions on reverse side.
2. Attach additional sheets as needed.

INSTRUCTIONS
All dams built with technical assistance from the Soil Conservation Service
must have a hazard classification assigned by the person responsible for
approving the design. Most farm ponds, except in borderline cases, can
be classified after a complete field investigation without assuming failure
and making breach studies. This data sheet is to be used for recording
the information obtained through field studies and for documenting the
hazard classification. Where there is a possibility for loss of life or
major property damage from a dam failure, an approved breach routing
procedure is to be used. (Consult with the area engineer.)
Hazard classifications of dams are made by evaluating the possibility
for loss of life and the extent of damage that would result if the dam
should suddenly breach --that is --a section of the dam be suddenly and
completely washed out. It is to be assumed that a wall of water will be
released equal to the height of the dam. This flood wave will be reduced
in height as it moves down the flood plain. The wave height (depth of
flooding) should be evaluated for a sufficient distance downstream until
the estimated flood level will not cause significant damage to improvements,
such as homes, buildings, roads, utilities, reservoirs, etc. The breach
flood level will be reduced depending on the valley storage, slope, and
openess of the flood plain; however, in a narrow steep valley slopes
steeper than 10% should be given special consideration. One method of
evaluation is to compare available valley storage (under flood conditions)
to impoundment storage (figured to the top of the dam) for each reach
evaluated with a judgment estimate made of the flood wave height at all
critical points downstream.
Should there be any questions about the hazard classification for a dam,
the area engineer should be consulted before making design commitments.

SCS-ENG•SM U. S. DEPARTMENT OF AGRICULTURE
R- 5-70 SOIL CONSERVATION SERVICE
SOIL INVESTIGATION TO DETERMINE SUITABILITY OF PROPOSED POND SITE
!. r
CROPLAND-1.4 owl
WATERSHED AREA MEASUREMENTS
WOODLAND -ACRES . •., . . .
ago
■
■
■■■■■■■■■■■■■■■■■■■■■
■
■■■■■■■■■■■■■■■■■■■■■
■■■■■■�■
■■ME■
MEN
■■■■■■mom
■■■■■■■■■■■■■■■■■■■■■■■■■■
■■■■■■■■■■■■■■■■■■■■■■■■■
■■■■■■■■■■■■■■■■■■■■■■■■■■
■■■■■■■■■■■■■■■■■■■■■■■■
■■■■■■■M■■■■■■■H■■■�■■■■■■
■■■■■■■■■■■■■■■■■■■■■■■■■■
■■■
MEN
■■■■■■■■■■■■■■■■■■■■■
■■■■■■■■■■■■■■■■■■■■
■■■■■
■■■■■■■■■■■■■■■■■■■■■■■■■
BORING. AND PROFILE
o©pro:©�oan'mmi©�mmmmmomo©goo
��®®I■I■�A�I■
■!■
■i■■I■i■i■■�■i■■
■i■
■tit
CEO=�7�'C'I!�!3'!
■I■''■!■
■'■'■i■I■
■I■'■I■I■'■i■
■!■I■
W.W.0101
■
MEMO
■■■■MII■■
MINIMUM
■■■!■
Imo!■;
!■'■■I■■■■■'■■I■■!■■I■i■■I■■■�
BORINGSMADEBY
,_

TYPES OF MATERIAL. ENCOUNTERED IN BORINGS
(Use one of.systems below)
UNIFIED CLASSIFICATION
USDA CLASSIFICATION
GW -Well graded gravels; gravel, sand mix
g - gravel
GP -Poorly graded gravels
s -sand
GM -Silty gravels; gravel -sand -silt mix
vfs - very fine sand
GC -Clayey gravels; gravel -sand -clay mix
sl-sandy loam
SW -Well graded sands; sand -grovel mix
fsl - fine sandy loam
SP -Poorly graded sands
1- loam
SM - Silty sand
gi -gravelly loam
SC -Clayey sands; sand -clay mixtures
si - silt
ML - Silts; silty, v. fine sands; sandy or clayey silt
sit -silt loam
CL - Clays of low to medium plasticity
cl - clay loam
CH - Inorganic clays of high plasticity
sicli- silty clay loam
MH -Elastic silts
scl -sandy clay loam
OL-Organic silts and silty clays, low plasticity
sic -silty clay
OH -Organic clays, medium 1to high plasticity
c-clay
L Suitable material for embankment is available (OYes Q No ondicar• wh~ rowr d on rh• sk*kh orr
rewrm BMW
REMARKS:
2. Explain hazards requiring special attention in design rScvuo., sztifrr0,. rock
GENERAL REMARKS: 54��'te rnTc��
C-TelY,�_,
\0 C6av{c5 E Wac� SGS
c a F- %A_ ID i 15 6Zc _
rJ-jrr"T rr �_'�rSC•rUt`tiprt •
24
26
26
27
28
29
30
31
32
33
34
35
36
37
30
39
40
41
42
43
44
46
46
47
4s
49
w
83

ATTIA�=- B
Agri -Waste Management
I;iok&.,da,,dAgric.,ZfundEngineering North Carolina SwL, Univ=&.1
L--V=-,O= WASTE S-OULINC, ANALXSZS AIM =-=LA':T.ON
OF LAM AP?LICA7IaH UTtS
James C. barker-
I. SAMPI—E CC—= ON
A. Sami-Solid Lac Hamra
L. Scraped directly from lot into spreader
a. From loaded spreader, collect about 2 lbs of manure from
d-If-farenc locations using acomecallic collectors.
LL. From storage
a. Collect about 2 lbs of manure from under the surface crust
avoiding bedding materials and using nonmetallic collectors.
Suirt
L Under-slactad- floor pi
-a Extend a 112* nonmetallic conduit open an bach ends into
manure to pit floor.
b. Seal %War end of conduit (e.g.. by pL%c:L=g a chumb aver and
of ConAttft) trapping mare that bas entered lower and, remove
and empty slurry into pLascic.buckat at nonmetallic container.
C. TAG subsAmplas from 3 at more locations or at la"z I quar---
d. Mix and add about 3/4 pLat to nonmetallic sample container.
ii. Exterior storage basin cc cask
a. Make sure manure has been veil mixed vizh a liquid manure
p "--p or propeller agitator.
b. Take subsa=zles from about 5 pit locaiiar-s, from agi=azar pu=;'
or from =anure spreader and place in a plastic bucket.
Professor and Extension Specialist. Biological and Agricultural Eazl=eecing
Deparz:zenc. tqor=h Carolina State Univers-1-cf. Raleigh. N.C.

'I ATTACii.'A=rr Et
2 of
• .- a. xLx and add 3/4 piac co a nonmetallic sample container,
C. Lagoon Liquid
L. Collect about 3/4 piac of recycled lagoon liquid from Lallow pipe
to flush Banks in a norssatallic sample container.
ii. From lagoon
a. Place a =-It battle (1/2 pint or less) on and of I0-L3pole.
b. Extend bottle IO-IS' away from bark edge.
c. 9rush away floaciag scum 'or debris.
d. Submerge bottle within V of liquid surface.
a. Empry into a plastic bucket, repeat about 5 times around
lagoon, mix. and add 3/4 pint to nonmetallic simple container.
D. Broiler or Turkey Litter
L. House litter
A. Visually inspec- litter for areas of varying quality. e.g..
zz.... - areas around. feeders and waterers. and estimate percent of
floor surface iix each area.
b. Take about 5•litter subsamples at locations proportionate to
item a. E.g.. if 20t of litter of similar visual quality is
around feeders and waterers,_cake I subsample there and the
othar 4 subsamples from remainder of floor surface.
~ e. At each location. collect litter from a 5" by V area dourt to
earth floor and place in a plastic bucket.
d. After 5 subsamples ha" been added to the bucket. mix. and add
about •2.3 lbs liztar to a nonmetallic sample container such as
- - - a 1-gallan freezer bag and Baal.
�U. From stockpile
a. Take subsamples from about 5 locations at least 18" inca pile.
b. Mix. add 2.3 lbs to nonmetallic sample container and seal.

ArrAu:�Nr n
3 of 3
II. SAWLT P38PARASION AND TUNSFE3
A. Placa sample into an expandable concainer that can be sealed. Rinse
residues from container with clean water but do nor use disinfectants,
soaps, or crest in any ocher way.
B. Pack sample in ice, refrigeraca, freeze, or cransfer to lab quickly.
C. Hand -delivery is most reliable way of sample transfer.
D. If mailed, protect sample container with packing material such as
newspaper, box or package with wrapping paper, and tape.
E. Commercial sample concainers and mailers are also available. Contacts:
L. AFL Easceza Agricultural lab, Inc. iii. Polyfoam Packers Corp.
7621 Vhitepine Road 2320 S. Foster Avenue
Richmond, CA 23237 Wheeling, IL 60090
Ph: [phone] Ph: [phone]
ii. Fisher Scientific Co. Lv. NASCO
3315 Vinton Road 901 Janesville Avenue
Raleigh, NC 27604 Fort Atkinson, VI 53538
Ph: [phone] Ph: [phone]
F. Private analytical labs are available, buc sample analyses are costly.
C. She NCDA provides this service for Nord: Carolina residents.
:' L. Address: North Carolina Department of Agrir:lture
Agronomic Division
Planr/Vaste/Solution Advisory Section
Blue Ridge Road Center
P.O. Box 27647
Raleigh. NC 27611
Ph: [phone]
Attn: Dr. Bay Campbell
Li. Forward $4 along with the sample.
iii. Include the following identification information with sample:
a. Livestock species (dairy, swine, turkey, act.)
Is. Livestock usage (seine -nursery, finishing; turkay-breeders,
brooderhouse, grower, number flocks grown on licter: etc.)
c. Vasce v1pe (dair;r-lac scraped manure, liquid slurry: swine -Pic
slurry, lagoon sludge; broiler -house licter, stockpile
iv. Routine analyses per -''cried an all samples: N, P. K. Ca, MS. Na,
S, Fe, v-:. 2n, Cu. B
v. Addicional analyses performed upon request: ON. Mo. Cd, Ni. Pb

MEMOO, .:
tI
"it
I +,V.
t o �I° t'
it
4
41
1 E" I `t I 1
41 4 I ► �, I,
4 14 #}}
lit
a

. ;
System Calibration
Information presented in manufacturer's charts are based on average operation
conditions with relatively new equipment. Discharge rates and application rates
change over time as equipment gets older and components wear. In particular,
pump wear tends to reduce operating pressure and flow. With continued use,
nozzle wear results in an increase in the nozzle opening which will increase the
discharge rate while decreasing the wetted diameter.
You should be aware that operating the system differently than assumed in the
design will alter the application rate, diameter of coverage, and subsequently the
application uniformity. For example, operating the system with excessive pressure
results in smaller droplets, greater potential for drift, and accelerates wear of the
sprinkler nozzle. Clogging of nozzles can result in pressure increase. Plugged
intakes or crystallization of mainlines will reduce operating pressure. Operating
below design pressure greatly reduces the coverage diameter and application
uniformity.
For the above reason, you should calibrate your equipment on a regular basis to
ensure proper application rates and uniformity. Calibration at least once every
three years is recommended. Calibration involves collecting and measuring flow at
several locations in the application area. Any number of containers can be used to
collect flow and determine the application rate. Rain gauges work best because
they already have a graduated scale from which to read the application amount
without having to perform additional calculations. However, pans, plastic buckets,
jars, or anything with a uniform opening and cross-section can be used provided
the liquid collected can be easily transferred to a scaled container for measuring.
For stationary sprinklers, collection containers should be located randomly
throughout the application area at several distances from sprinklers. For traveling
guns, sprinklers should be located along a transact perpendicular to the direction
of pull. Set out collection containers 25 feet apart along the transact on both
sides of the gun cart. You should compute the average application rate for all
nonuniformity of the application. On a windless day, variation between containers
of more than 30 percent is cause for concern. You should contact your irrigation
dealer or technical specialist for assistance.
*Reprinted for Certification Training for Operations of Anima/ Waste Management Systems Manna/

OPERATION & MAINTENANCE PLAN
Proper lagoon liquid management should be a year-round priority. It is especially
important to manage levels so that you do not have problems during extended rainy and
wet periods_
Maximum storage rapacity should be available in the lagoon for periods when the
receiving crop is dormant (such as wintertime for bermudagrass) or when there are
extended rainy spells such as the thunderstorm season in the summertime. This means
that at the first signs of plant growth in the later winter/early spring, irrigation according to
a farm waste management plan should be done whenever the land is dry enough to
receive lagoon liquid. This will make storage space available in the lagoon for future wet
periods. In the late summerlearly fall the lagoon should be pumped down to the low
marker (see Figure 2-1) to allow for winter storage. Every effort should be made to
maintain the lagoon close to the minimum liquid level as long as the weather and waste
utilization plan will allow it.
Waiting until the lagoon has reached its maximum storage capacity before starting to
irrigate does not leave room for storing excess water during extended wet periods.
Overflow from the lagoon for any reason except a 25-year, 24-hour storm is a violation of
state law and subject to penalty action.
The routine maintenance of a lagoon involves the following:
Maintenance of a vegetative cover for the dam.
Fescue or common bermudagrass are the most common vegetative
covers. The vegetation should be fertilized each year, if needed, to
maintain a vigorous stand. The amount of fertilizer applied should be
based on a soils test, but in the event that it is not practical to obtain
a soils test each year, the lagoon embankment and surrounding areas
should be fertilized with 800 pounds per acre of 10-10-10, or
equivalent.
Brush and trees on the embankment must be controlled. This may be
done by mowing, spraying, grazing, chopping, or a combination of
these practices. This should be done at least once a year and
possibly twice in years that weather conditions are favorable for
heavy vegetative growth.
NOTE: If vegetation is controlled by spraying, the herbicide must not be allowed to enter
the lagoon water. Such chemicals could harm the bacteria in the lagoon that are treating
the waste.
Maintenance inspections of the entire lagoon should be made during the initial filling of
the lagoon and at Ieast monthly and after major rainfall and storm events. Items to be
checked should include, as a minimum, the following:
Waste Inlet Pipes, Recycling Pipes, and Overflow Pipes ---look for.
1. separation of joints
2. cracks or breaks
3. accumulation of salts or minerals
4. overall condition of pipes

Lagoon surface --look for.
1. undesirable vegetative growth
2. floating or lodged debris
Embankment —look for:
1. settlement, cracking, or jug" holes
2. side slope stability —slumps or bulges
3. wet or damp area on the back slope
4. erosion due to lack of vegetation or as a result of wave action
5. rodent damage
Larger lagoons may be subject to liner damage due to wave action caused by strong
winds. These waves can erode the lagoon sidewalls, thereby weakening the lagoon dam.
A good stand of vegetation will reduce the potential damage caused by wave action. If
wave action causes serious damage to a lagoon sidewall, baffles in the lagoon may be
used to reduce the wave impacts.
Any of these features could lead to erosion and weakening of the dam. If your lagoon has
any of these features, you should call an appropriate expert familiar with design and
construction of waste lagoons. You may need to provide a temporary fix if there is a threat
of a waste discharge. However, a permanent solution should be reviewed by the
technical expert. Any digging into a lagoon dam with heavy equipment is a serious
undertaking with potentially serious consequences and should not be conducted unless
recommended by an appropriate technical expert.
Transfer Pumps --check for proper operation of:
1. recycling pumps
2. irrigation pumps
Check for leaks, loose fittings, and overall pump operation. An unusually loud or grinding
noise, or a large amount of vibration, may indicate that the pump is in need or repair or
replacement.
NOTE: Pumping systems should be inspected and operated frequently enough so that you
are not completely "surprised" by equipment failure. You should perform your pumping
system maintenance at a time when your lagoon is at its low level. This will allow some
safety time should major repairs be required. Having a nearly full lagoon is not the time
to think about switching, repairing , or borrowing pumps. Probably, if your lagoon is full,
your neighbor's lagoon is full also. You should consider maintaining an inventory of spare
parts or pumps.
Surface water diversion features are designed to carry all surface
drainage waters (such as rainfall runoff, roof drainage, gutter outlets,
and parking lot runoff) away from your lagoon and other waste
treatment or storage structures. The only water that should be
coming from your lagoon is that which comes from your flushing
(washing) system pipes and the rainfall that hits the lagoon directly.
You should inspect your diversion system for the following:
1. adequate vegetation
2. diversion capacity
3. ridge berm height

Identified problems should be corrected promptly. It is advisable to inspect your system
during or immediately following a heavy rain. If technical assistance is needed to
determine proper solutions, consult with appropriate experts.
You should record the level of the lagoon just prior to when rain is predicted, and then
record the level again 4 to 6 hours after the rain (assumes there is no pumping). This will
give you an idea of how much your lagoon level will rise with a certain rainfall amount
(you must also be recording your rainfall for this to work). Knowing this should help in
planning irrigation applications and storage. If your lagoon rises excessively, you may
have an inflow problem from a surface water diversion or there may be seepage into the
lagoon from the surrounding land.
Lagoon Operation
Startup:
1. Immediately after construction establish a complete sod cover on bare soil
surfaces to avoid erosion.
2. Fill new lagoon design treatment volume at least half full of water before
waste loading begins, taking care not to erode lining or bank slopes.
3. Drainpipes into the lagoon should have a flexible pipe extender on the
end of the pipe to discharge near the bottom of the lagoon during initial
filing or another means of slowing the incoming water to avoid erosion of
the lining.
4. When possible, begin loading new lagoons in the spring to maximize
bacterial establishment (due to warmer weather).
5. It is recommended that a new lagoon be seeded with sludge from a healthy
working swine lagoon in the amount of 0.25 percent of the full lagoon
liquid volume. This seeding should occour at least two weeks prior to the
addition of wastewater.
6. Maintain a periodic check on the lagoon liquid pH. If the pH falls below
7.0, add agricultural lime at the rate of 1 pound per 1000 cubic feet of
lagoon liquid volume until the pH rises above 7.0. Optimum lagoon liquid
pH is between 7.5 and 8.0.
7. A dark color, lack of bubbling, and excessive odor signals inadequate
biological activity. Consultation with a technical specialist is recommended
if these conditions occur for prolonged periods, especially during the warm
season.
Loading:
The more frequently and regularly that wastewater is added to a lagoon, the better the
lagoon will function. Flush systems that wash waste into the lagoon several times daily are
optimum for treatment. Pit recharge systems, in which one or more buildings are drained
and recharged each day, also work well.

Practice water conservation —minimize building water usage and
spillage from leaking waterers, broken pipes and washdown through
proper maintenance and water conservation.
Minimize feed wastage and spillage by keeping feeders adjusted. This
will reduce the amount of solids entering the lagoon
Management:
. Maintain lagoon liquid level between the permanent storage level and
the full temporary storage level.
Place visible markers or stakes on the lagoon bank to show the
minimum liquid level and the maximum liquid lever figure 2-1).
Start irrigating at the earliest possible date in the spring based on
nutrient requirements and soil moisture so that temporary storage
will be maximized for the summer thunderstorm season. Similarly,
irrigate in the late summer/early fall to provide maximum lagoon
storage for the winter.
The lagoon liquid level should never be closer than 1 foot to the lowest
point of the dam or embankment.
Do not pump the lagoon liquid level lower that the permanent storage
level unless you are removing sludge.
Locate float pump intakes approximately 18 inches underneath the liquid
surface and as far away from the drainpipe inlets as possible.
Prevent additions of bedding materials, long-stemmed forage or vegetation,
molded feed, plastic syringes, or other foreign materials into the lagoon.
Frequently remove solids from catch basins at end of confinement houses or
wherever they are installed.
Maintain strict vegetation, rodent, and varmint control near lagoon edges.
Do not allow trees or large bushes to grow on lagoon dam or embankment.
Remove sludge from the lagoon either when the sludge storage capacity is
full or before it fills 50 percent of the permanent storage volume.
If animal production is to be terminated, the owner is responsible for
obtaining and implementing a closure plan to eliminate the possibility of a
pollutant discharge.
Sludge Removal:
Rate of lagoon sludge buildup can be reduced by:

proper lagoon sizing,
mechanical solids separation of flushed waste,
gravity settling of flushed waste solids in an appropriately designed basin, or
minimizing feed wastage and spillage.
Lagoon sludge that is removed annually rather than stored long term will:
have more nutrients,
have more odor, and
require more land to properly use the nutrients.
Removal techniques:
Hire a custom applicator.
Mix the sludge and lagoon liquid with a chopper -agitator impeller
pump through Iarge-bore sprinkler irrigation system onto nearby cropland;
and soil incorporate.
Dewater the upper part of lagoon by irrigation onto nearby cropland or
forageland; mix remaining sludge; pump into liquid sludge applicator, haul
and spread onto cropland or forageland; and soil incorporate.
Dewater the upper part of lagoon by irrigation onto nearby cropland or
forageland; dredge sludge from lagoon with dragline or sludge barge; berm
an area beside lagoon to receive the sludge so that liquids can drain back
into lagoon; allow sludge to dewater, haul and spread with manure spreader
onto cropland or forageland; and soil incorporate.
Regardless of the method, you must have the sludge material analyzers for waste
constituents just as you would your lagoon water. The sludge will contain different
nutrient and metal values from the liquid. The application of the sludge to fields will be
limited by these nutrients as well as any previous waste applications to that field and crop
requirement. Waste application rates will be discussed in detail in Chapter 3.
When removing sludge, you must also pay attention to the liner to prevent damage. Close
attention by the pumper or drag -line operator will ensure that the lagoon liner remains
intact. If you see soil material or the synthetic liner material being disturbed, you should
stop the activity immediately and not resume until you are sure that the sludge can be
removed without liner injury. If the liner is damaged it must be repaired as soon as
possible.
Sludge removed from the lagoon has a much higher phosphorus and heavy metal content
than liquid. Because of this it should probably be applied to land with low phosphorus
and metal levels, as indicated by a soil test, and incorporated to reduce the chance of
erosion. Note that if the sludge is applied to fields with very high soil -test phosphores, it
should be applied only at rates equal to the crop removal of phosphorus. As with other
wastes, always have your lagoon sludge analyzed for its nutrient value.
The application of sludge will increase the amount of odor at the waste application site.
Extra precaution should be used to observe the wind direction and other conditions which
could increase the concern of neighbors.

Possible Causes of Lagoon Failure
Lagoon failures result in the unplanned discharge of wastewater from the structure. Types
of failures include leakage through the bottom or sides, overtopping, and breach of the
dam. Assuming proper design and construction, the owner has the responsibility for
ensuring structure safety. Items which may lead to lagoon failures include.
Modification of the lagoon structure —an example is the placement of a pipe
in the dam without proper design and construction. (Consult an expert in
lagoon design before placing any pipes in dams.)
Lagoon liquid levels —high levels are a safety risk.
Failure to inspect and maintain the dam.
Excess surface water flowing into the lagoon.
Liner integrity —protect from inlet pipe scouring, damage during sludge
removal, or rupture from lowering lagoon liquid level below groundwater
table.
NOTE: If lagoon water is allowed to overtop the dam, the moving water will soon cause
gullies to form in the dam. Once this damage starts, it can quickly cause a large discharge
of wastewater and possible dam failure.

EMERGENCY ACTION PLAN
PHONE NUMBERS
DIVISION OF WATER QUALITY (DWQ) 31ca
EMERGENCY MANAGEMNET SERVICES (EMS) qw 6yc 6E10
SOIL AND WATER CONSERVATION DISTRICT (SWCD) 910 444 a y8
NATURAL RESOURCES CONSERVATION SERVICE (NRCS)gip 64,4 33ge
COOPERATIVE EXTERSION SERVICE (CES) _Ctia &�a f&os
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing or running off site. You should not wait until wastes reach surface waters
or leave you property to consider that you have a problem. You should make every
effort to ensure that this does not happen. This plan should be posted in an accessible
location for all' employees at the facility. The following are some action items you should
take.
1. Stop the release of wastes. Depending on the situation, this may ore may not be
possible. Suggested responses to some possible problems are listed belwo.
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Cali a pumping contractor.
e. Make sure no surface water is entering lagoon.
B. Runoff from waste application field. -actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that cause the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinklers -action include: .
a. Stop recycle pump.
b. Stop irrigation pump.
C. Close valves to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
D. Leakage from flush systems, houses, solid separators -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed
to flowing leaks -possible action:
a. Dig a small sump or ditch from the embankment to catch all
seepage, put in a submersible pump, and pump back to lagoon.
b. if holes are caused by burrowing animals, trap or remove animals and fill
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon
bottom as soon as possible.
1

2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what duration?
c. Any damage notes, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours call your DWQ regional office; Phone - -. After
hours, emergency number: 919-733-3942. Your phone call should include: your
name, facility number, telephone number, the details of the incident from item 2
above, the exact location of the facility, the location or direction of movement of
the spill, weather and wind conditions. The corrective measures that have been
under taken, and the seriousness of the sitution.
b. If spill leaves property or enters surface waters, call local EMS phone number.
c. Instruct EMS to contact local Helath Department.
d. Contact CEs, phone number - , local SWCD office phone number - -, and local
NRCS office for advice/technical assistance phone number - -.
4. If none of the above works call 911 or the Sheriff's Department and explain you
problem to them and ask the person to contact the proper agencies for you.
5. Contact the contractor of your choice to begin repair or problem to minimize off -
site damage.
a. Contractors Name: (*.J- 4.11 CD.-"
b. Contractors Address: aZ1,5 r
Is,-
c. Contractors Phone: -Irp G49-'7Sn3
6. Contact the technical specialist who certified the lagoon (NRCS, Consulting
Engineer, etc.)
a. Name:,
b. Phone:33`l$
7. Implement procedures as advised by DWQ and technical assistance agencies to
rectify the damage, repair the system, and reassess the waste managment plan to
keep problems with release of wastes from happening again.
2

INSECT CONTROL CHECKLIST FOR ANIMAL OPERATIONS
Source Cause BMP's to Minimize Odor Site Specific Practices
(Liquid Systems)
Flush Gutters Accumulation of solids ush system is designed and operated
sufficiently to remove accumulated
sds from gutters as designed.
(,)'Remove bridging of accumulated solids at
discharge
Lagoons and Pits Crusted Solids (a`Malntain lagoons, settling basins and
pits where pest breading is apparent to
minimize the crusting of solids to a depth
of no more than 6-8 inches over more than
30% of surface.
Excessive Vegetative Decaying vegetation (Maintain vegetative control along banks of
Growth lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along water's edge on impoundment's perimeter.
(Dry Systems)
Feeders Feed Spillage ("esign, operate and maintain feed systems (e.g.,
bunkers and troughs) to minimize the accumulation
/of decaying wastage.
M Clean up spillage on a routine basis (e.g. 7-10 day
interval during summer, 16-30 day interval during winter).
Feed Storage Accumulations of feed residues {) Reduce moisture accumulation within and around
Immediate perimeter of feed storage areas by
Insuring drainage away from site and/or providing
adequate containment (e.g., covered bin for
brewer's grain and similar high moisture grain
products).
() Inspect for and remove or break up accumulated
solids in filter strips around feed storage as needed.
Animal Holding Areas Accumulations -of animal wastes ( ) Eliminate low area that trap moisture along fences
and feed wastage and other locations where waste accumulates and
and disturbance by animals is minimal.
() Maintain fence rows and filter strips around animal
holding areas to minimize accumulations of wastes
(i.e. inspect for and remove or break up accumulated
solids as needed).
AMIC—November 11, 1996

Dry Manure Handling Accumulations of animal wastes () Remove spillage on a routine basis (e.g. 7-10 day
systems intend during summer. 15-30 days interval during
winter) where manure is loaded for land application
or disposal. '
() Provide for adequate drainage around mamre stockpiles.
() Inspect for and remove or break up accumulated wastes
in filter stripes around stockpiles and manure hrd6rp
areas as needed.
The issues checked ( ) pertain to this operation. The iandownerfrntegrator agrees to use sound judgment in applying
insect control measures as practical.
I certify the aforementioned insect control Best Management Practices have been reviewed with me.
AJ�Jfzzt!zz
(landowner Signature)
For more information contact the Cooperative Extension Service, Department of Entomology, Box 7613, North Carolina State University, Raleigh, NC
27695-7613.
AMIC—November 11. 1996

SWINE FARM WASTE MANAGEMENT ODOR CONTROL CHECKLIST
Source Cause BMP's to Minimize Odor Site Specific Practices
Farmstead Swine production (- vegetative or wooded buffers;
"Recommended best management
actices;
� �GGood judgment and common sense
Animal body surfaces Dirty manure -covered animals (�! DM floors
Floor surfaces Wet manure -covered floors fi Slotted floors;
( F=erers located over slotted floors;
ers at high and of solid floors;
f�i Serape manure buildup from floors;
(} Underfloor ventilation for drying
Manure collection pits Urine Frequent manure removal by flush,pit
recharge,or scrape
Perital micorbial decomposition (} Underfloor ventilation
Ventilation exhaust fans Volatile gases; ( n maintenance;
Dust {'] Efficient air movement
Indoor surfaces Dust ashdown between groups of animals
(} Feed additives;
(} Feeder covers;
(} Feed delivery downspout extenders to
feeder covers
Flush tanks Agitation of recycled lagoon (} Flush tank covers
liquid whiles tanks are filling (} Extend fill lines to near bottom of
tanks with anti -siphon vents
Rush alleys Agitation during wastewater ( Underfloor flush with underfloor
conveyanance ventilation
Pit recharge points Agitation of recycled lagoon { } Extend reehard lines to near bottom of
liquid while pits are filling pits with anti -siphon vents
Lift stations Agitation during sump tank filling { } Sump tank covers
and drawdown
Outside drain collection Agitation during wastewater ( } Box covers
or junction boxes conveyance
End of drainpipes at lagoon Agitation during wastewater {) Extend discharge point of pipes
underneath lagoon liquid level
Lagoon surfaces Volatile gas emissions (- Proper lagoon liquid capacity
Biological mixing (} Correct lagoon startup procedures
Agitation K Minimum surface area -to -volume ratio
{) Minimum agitation when pumping
{) Mechanical aeration
(} Proven biological additives
Irrigation sprinkler nozzles High pressure agitation Irrigate on dry days with little or no wind
Wind draft (Lf Minimum recommended operation pressure
Pump intake near lagoon liquid surface
( ) Pump from second -stage lagoon
AMOC—November 11, 1996

a Storage tank or basin
Partial microbial decomposition
( 1 Bottom or midlevel loading
surface
Mixing whit, toying
1) Tank covers
Agitation when emptying
l) Basin surface mats of solids
( ) Proven biological additives or oxidants
Settling basin surface
Partial micobial decomposition
( ) Extend drainpipe outlets underneath liquid
Mbdng while filling
level
Agitation when emptying
() Remove settled solids regularly
Manure, slurry or sludge
Agitation when spreading
() Sail injection of slurry/sludges
spreader outlets
Volatile gas emissions
() Wash residual manure from spreader after use
() Proven biological additives or oxidants
Uncovered manure, slurry Volatile gas emissions while drying () Soil infection of slurry/sludges
or sludge on field surfaces _ () Soil incorporation within 48 hours
() Spread in thin uniform layers for rapid drying
( ) Proven biological additive. or oxidants
Dead animals Carcass decomposition ji=per disposition of carcasses
Dead animal disposal Carcass decomposition () Complete covering of carcasses in burial pits
pits () Proper location/construction of disposal pits
Incinerators
Incomplete combustion
( ) Secondary stack burners
Standing water around
Improper drainage
(Grade and landscape such that water drains
facilities
Microbial decomposition of
away from facilities
organic matter
Manure tracked onto public
Poorly maintained access roads
(-YFenn access road maintenance
roads from farm access
Additional Information: Available From:
Swine Manure Management; 0200 RUIe/BMP Packet
NCSU-County Extension Center
Swine Production Farm Potential Odor Sources and Remedies, EBAE Fact Sheet
NCSU-BAE
Swine Production Facility Manure Management: Pit Recharge —Lagoon Treatment;. EBAE 128-88
NCSU-BAE
Swine Production Facility Manure Management: Underfloor Russ —Lagoon Treatment; EBAE 129-88
NCSU-BAE
Lagoon Desig and Management for Livestock Manure Treatment and Storage; EBAE 103-83
NCSU-BAE
Calibration of Manure and Wastewater Application Equipment. EBAE Fact Sheet
NCSU-BAE
Controlling Odors from Swine Buildings; PIN-33
NCSU-Swine Extension
Environmental Assuranc Program: NPPC Manual
NC Pork Produces Assoc
Options for Managing Odor; a report from the Swine Odor Task Force
NCSU Agri Communications
Nuisance Concerns in Animal Manure Management: Odors and Ries; PR0107, 1995 Conference Proceedings
Florida Cooperative Extension
The issues checked ( ) pertain to this operation. The landownerrintegrator agrees to use sound judgment in applying
odor control measures as practical.
I certify the aforementioned odor control Best Managment Practices ha a been reviewed with me.
(Landowner Signature)
AMOC—November 11, 1996

4 � w
MORTALITY MANAGEMENT METHODS
(check which method(s) are being implemented)
{ j Burial three feet beneath the surface of the ground within 24 hours
after knowledge of the death. The burial be at least 300 feet from
any flowing steam or public body of water.
{ ...� Rendering at a rendering plant licensed under G. S. 106-168.7
( ) Complete incineration
{ ) In the case of dead poultry only, placing in a disposal pit of a size and
design approved by the Department of Agriculture.
{ ) Any method which in the professional opinion of the State
Veterinarian would make possible the salvage of part of a dead
animal's value without endangering human or animal health. (Written
approval of the State Veterinarian must be attached)

Mummumrot.a rLIN■E■wwM

e
\Va�
StateNorth Carolina
Department of 1=nvironment Avail
and Natural Fieuources `'�'zL M;)�Division of Water Quality 1It
A$ � urslc
Samos B. Hunt, Jr., Governor
J NCDENR
Wayne McDevitt. Secretary ()F' "A)O f % S Ncasm CARouNA Deretrtmmlm ap
A- Preston Howard, Jr., P.E., Director 1 ENWRONMEKT ANO NdURnL P'==RC=
idy 21; 1998
Darrell Storks
Darrell Stocks Farm
12559 Swamp Fox Rwy-E
Tabor City NC 2W3
Snbje= ApplieatitutNo. 24-M
Additional lnfomtatinn R-quest
Llanall Stock3 Famt
Animal Waste Operation
Colinobas Ctmaty
near Darren Stacks:
The Non -Discharge Pennimng Unit Las eomple= a ptclimltiaty review of tlx: subject application.
AdditiO21 tnformati0n is ltquired before we can condmic our review. The following oompoeent was tni4sing
from your Certified Animsi waste Management Plan:
1) The Waste Utilization Plan (VirtJP) lists soybeans, cam and wbmat in a two-year rotation as
available crops for waste application Residual nitrogen left over from the soybean crop m the
two-year rotation mast be 8ccotmted for. Mtrogen application rates to the following crop are
required to be reduced by 15.30 IL (dependent on 3oll type) to aceauatfor the r.9dual nitogen
left by the preceding soybean crop. Please tevise yarn. WUP to properly list all application rates
with residual nitrogen incorporated into your ctnpping schetue,
All revisions / atneudnreats ate required to be signed and datedby boot the landowner and the Toaft"
Specialist before they ate submitted far review. Please reference the 3ubjeet permit application number wben
providing the requested hd=ialft m. All infortaadon should be signed and submitted in duplicate to my attention
at the address below. The irew=tiea requeekd by this letter, Dinar be submitted en nr baFmc August 21,19w ere
the Division will retum your appicadoa as incomplete in accordance with 15A N.C.A.C. 2H .0200 and your
facility will he considered to be operating without a permit.
Please be advised that operation. of the subject ildrnsl waste rumgealent sysran wwwrit a valid permit in
a violation of North Carolina General Stanue 143,215. i and will subject you to the —fore menr authority of the
Environmental Management CommissiorL
tf you have any questions regarding this request, please call me at [phone], extertsion 533.
Katharine Kedon
soil Scientist
Non -Discharge Permitting Unit
tc: Wil®ugtMReOotWoffice.Wc=Quality
Permit File
P.O. Box 29535, Ralelch, North Cafollna 27626-0535 Telephone [phone] FAX 919-iMOns
An Equal OppaRuniry Arirmatl a Action Employer 50% MaYrAw 10% Past-ca,e r Pater
10018 SHOOd,S 111am(I MCI C29 OT6 Iva MST MU 96/91/+ 0

AC,
..
Table 1: ACRES OWNED BY PRODUCER
Tract Feld Sm7 Crop Lbs. N Acres Lhs. N Month of
# No. Type Per Ac. * Utffind Application
WIN
437��
���/'�`���G��
Q��`'�G��7
s
y�i�
�'-�MOME�.
"MI
T oW I I
10

mr,111TAT&I
-a
LWXIZLMWA I - I I M

State of North Carolina
Department of Environment
and Natural Resources RECENED 4 • Division of Water Quality APR 17 1998
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary BY -
A. Preston Howard, Jr., P.E., Director
April 17, 1998
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Darrell Stocks
Darrell Stocks Farm
Rt 3 Box 217
Tabor City NC 28463
Farm Number: 24 - 6
Dear Darrell Stocks:
You are hereby notified that Darrell Stocks Farm, in accordance with G.S. 143-215.1OC, must apply for
coverage under an Animal Waste Operation General Permit. Upon receipt of this letter, your farm has six 60
days to submit the attached application and all supporting documentation. In accordance with Chapter 626 of
1995 Session Laws (Regular Session 1996), Section 19(c)(2), any owner or operator who fails to submit an
application by the date specified by the Department SHALL NOT OPERATE the animal waste system
after the specified date. Your application must be returned within sixty (60) days of receipt of this letter.
Failure to submit the application as required may also subject your facility to a civil penalty and other
enforcement actions for each day the facility is operated following the due date of the application.
The attached application has been partially completed using information listed in your Animal Waste
Management Plan Certification Form. If any of the general or operation information listed is incorrect please
make corrections as noted on the application before returning the application package. The signed original
application, one copy of the signed application, two copies of a general location map, and two copies of the
Certified Animal Waste Management Plan must be returned to complete the application package. The completed
package should be sent to the following address:
North Carolina Division of Water Quality
Water Quality Section
Non -Discharge Permitting Unit
Post Office Box 29535
Raleigh, NC 27626-0535
If you have any questions concerning this letter, please call Mike Lewandowski at [phone]
extension 362 or Dave Holsinger with the Wilmington Regional Office at [phone].
Sincerely,
A. Preston Howard, Jr., P.E.
cc: Permit File (w/o encl.)
Wilmington Regional Office (w/o encl.)
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50 % recycled/ 10 % post -consumer paper

TEL: Feb 20'98 10:06 Na.002 P.01
r
No NORTH CAROLINA DEPARTMENT OF
Kr%MIt0NMENT AND NATURAL RESOURCES
DIVIBION OF SOIL AND WATER CONSERVATION
To: Andy Hchninger
From: Audrey Oxendinoo - —
RL: Farms with less t1m 7" o£Frieeboard
Date: February 20, 1998 =
I revived a complaint ou several h= on 2-18-98. After checking these
farms, the follcrw ing warn found to have less than 7" of freeboard:
Darrell Stocks
24-76--
State Line #1&#2
Darrell Stocks
24-6
Darrell Stocks Farm
Coastal Farms
24-9
Coastal Farms #2&#3
Gaye Crowther
24-13
Seawright Farm
I am working with these producers to try to lower these lagoons. Both W.
Stocks farms have been depopulated { 1 house was to be removed today) and
he has irrigation equipment in place to spray on the driest areas. Coastal
Fames has notified you of tlieir situation. Prestage has brought in additional
irrigation equipment to spray. I have beer► in contact with Ms. Crowther and
they plan to add clay to the low spot in the, wall to give additional freeboard,
Please see the inspection rWortts in the database for more detailed
information.
RC. SaK 270". RALKIOM, NOR7N CAROLINA 2781 4-7667
PweMe oln_y>?g-'19Ox Pwx .1O-7laaoae
AN KQUAL OPTORTUNITYIAPPIRMAnVt ACTIpN LMIPLOn*-90% RECYCLEW10% POST-CONRUNLR PAPER

,-a
IF
�
i r
IH
;may 1
Ea
�
$
a
o
Q
gg
--
m
m
m
r
? I—
y
O
$
V
S •6
c
C p
5= s
t
a
E E
R
8
m SENDER:
L +Complete items t anNor 21or eaditionat serviced
I also wish to receive the
a •complete items 3, 4a, and 4b.
following services (for an
a • Pnm your name and address m the reverse of this form so that we
can return this
extra fee):
card to you.
•Attach this form to the trout of the maitpiew, erdrt.the §'aaf rf space does not
1. ❑ Addressee's Address -
m permit.
m Write 'Return Receipt Requested'on the mailpiece below the article number
-
2.❑ Restricted Delivery to
•The Return Receipt will Shaw to whom the article was delivered and the date
delivered.
Consult postmaster for fee. `
o
n 3. Article Addressed to:
0./IJLQjpI(X s�
49L Article Number cm
2 3 (a AI s 7s
T
((1
4b. Service Type m
❑ Registered ertifiecl ¢ '
❑ Express Mail ❑ Insured W
r
m -
4 "
n� C
O 11Reoeiptfor.rchantAse ❑ COD
7. D e of Delivery
-
5. Received By: (Pdnt Name)
8. Addressee's Address (Only if requested
-
end fee is paid) c
g 6. nature ( dress or Agent) -
0
~
A
7 Ps Form 3811, D e er1994 ; t 102595-97� 179 Domestic Return Receipt

State of North Carolina
Department of Environment
and Natural Resources
Wilmington Regional Office
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
Division of Water Quality
January 20, 1998
Certified Mail # Z 312 648 575
Return Receipt Requeste
Darrell Stocks
Darrell Stocks Farm
Rt3Box 217
Tabor City, North Carolina 28463
NCDENR
NORTH CAROLINA DEPARTMEtn OF
Emm RONMEN7 AND NAzruRAL RESOuRcr%
Subject: NOTICE OF DEFICIENCY
Darrell Stocks Farm
Facility Number: 24-6
Columbus County
Dear Mr. Stocks:
On January 15, 1998, staff from the Wilmington Regional Office of the Division of Water
Quality performed a follow up inspection on your animal operation. During the inspection, it
was observed that your lagoon had less than 19 inches of available freeboard. While no
discharge of waste was observed to waters of the State at the time of inspection, any rainfall
event could likely result in the discharge of waste from the lagoon. The level of your lagoon
should be lowered and maintained in accordance with the NRCS guidelines and the state 2H
.0200 rules governing animal waste management systems.
USDA -MRCS guidelines require a minimum of one foot and seven inches of freeboard.
This is based on the amount of storage space needed to contain a 25-year, 24 hour design
storm event without a discharge. NRCS requirements also specify that animal waste shall be
applied on actively growing crops and that waste nutrients shall not be applied in fall or winter
for spring planted crops on soils with a high potential for leaching. Waste nutrient loading
rates on these soils should be held to a minimum and a suitable winter cover crop planted to
take up released nutrients.
127 North Cardinal Dr., Wilmington, North Carolina 28405 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

Darrell Stocks
January 20, 1998
Page 2
To remain a deemed permitted facility, you must notify this office in writing within
fourteen (14) days of the receipt of this notice, what actions have been taken to correct this
deficiency. Failure to do so may result in the facility losing its deemed permitted status,
requiring it to obtain an individual non discharge permit.
Please be aware it is a violation of North Carolina General Statutes to discharge waste
water to the surface waters of the State without a permit. The Division of Water Quality has
the authority to levy a civil penalty of not more than $10,000 per day per violation.
If you have any questions concerning this matter, please call Andy Hehninger, Dave
Holsinger, or Brian Wrenn at 910-395-3900.
Sincerely,
a_.L� xj fix,.
Andrew G. Hehninger
Environmental Specialist
cc: Donna Register, Columbus County Soil and Water Conservation
Sandra Weitzel, N.C. Division of Soil and Water Conservation
Audrey Oxindine, N.C. Division of Soil and Water Conservation
Garth Boyd, Murphy Family Farms
Operations Branch
Wilmington Files
S: I WQS I ANDYA 124-6. D EF
127 North Cardinal Dr., Wilmington, North Carolina 28405 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50 % recycled/10 % post -consumer paper

Rt. 3, Box 217
Tabor City, NC 28463
February 2, 1998
Andrew G. Helminger
127 North Cardinal Dr.
Wilmington, NC 28405
RE: Darrell Stocks Farm
State Line Farms #1& #2
Dear Mr. Helminger:
Facility #24-6
Facility 424-76
Zy -
ElVED�P�,g
FEB 0 5 1998
E
I have received your Notice of Deficiency dated January 20, 1998. The following items
will be addressed:
1. The lagoons will be lowered to the required 19" freeboard as soon as the
weather and soils allow an irrigation event.
2. Bare areas on the lagoons will be reseeded in the spring when vegetative
growth can be better established.
Sint ly,
3
I
Darrell Stocks
cc: Murphy Family Farms
Donna Register, Columbus Co. NRCS
r�

State of North Carolina
Department of Environment,
Health and Natural Resources
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
Darrell Stocks
Stocks Farm
Rt3Box 217
Tabor City NC 28463
&J�LA..
EDEHNR
November 13, 1996
SUBJECT: Operator In Charge Designation
Facility: Stocks Farm
Facility ID#: 24-6
Columbus County
I0?TiuraYMIT;
Senate Bill 1217, An Act to Implement Recommendations of the Blue Ribbon Study
Commission on Agricultural Waste, enacted by the 1996 North Carolina General Assembly,
requires a certified operator for each animal waste management system that serves 250 or more
swine by January 1, 1997. The owner of each animal waste management system must submit a
designation form to the Technical Assistance and Certification Group which designates an
Operator in Charge and is countersigned by the certified operator. The enclosed form must be
submitted by January 1, 1997 for all facilities in operation as of that date. Failure to designate a
certified operator for your animal waste management system is a violation of 15A NCAC 2H
.0224 and may result in the assessment of a civil penalty.
If you have questions concerning operator training or examinations for certification, please
contact your local North Carolina Cooperative Extension Service agent or our office.
Examinations have been offered on an on -going basis in many counties throughout the state for
the past several months and will continue to be offered through December 31, 1996.
Thank you for your cooperation. If you have any questions concerning this requirement please
call Beth Buffington or Barry Huneycutt of our staff at 919n33-0026.
Sincerely,
A. Preston Howard, Jr., P.E. D' ctor
Division of Water Quality
Enclosure
cc: Wilmington Regional Office
Water Quality Files
P.O. Box 27687, N%�«, FAX [phone]
Raleigh, North Carolina 27611-7687 1, An Equal FAX
Action Employer
Voice 919-715-4100 50% recycled/100/ post -consumer paper

w '-
REGISTRATION FORM FOR ANIMAL FEEDLOT OPERAT ONS
Department of Environment, Health and Natural "sours�`,�
Division of Environmental Management -Y
Water Quality Section Y_.11AC'
oc�
If the animal waste management system for your feedlo ,,operationr'L
is designed to serve more than or equal to 100 head of s -t I
horses, 250 swine, 1,000 sheep, or 30,000 birds that are
by a liquid waste system, then this form must be filled out and
mailed by December 31, 1993 pursuant to 15A NCAC 2H.0217 (c) in
order to be deemed permitted by DEM. Please print clearly.
Farm Name: Stocks Farm
Route 3 Box 217
Tabor City, NC 28463
Columbus County 919-653-9386(H)/3746(M)/540-3530(C)
Owner(s) Name: ) ,A r _I' 'L j To C /l.
Manager(s) Name:
Lessee Name: From Whiteville take US 701 By -Pass S to
pickup NC 130 E towards Brunswick, go
Farm Location (Be as specific as possible: thru Brunswick on NC 130 for another 3.4
direction, milepost, etc.): ,� �n�, miles and turn Rt. onto NC 905 S, follow
NC 905 S to Bug Hill, turn Rt. onto SR
- 1112 for 1.6 miles where SR 1112 merges
into SR 1108, follow SR 1108 to
intersection of NC 904, turn Lt. on NC
904, go 1.0 mile to farm entrance on Lt.
(TT=2 hrs.; TD=90 miles)
Latitude/Longitude if known: QBSP # Q3-113�-C3
Design capacity of animal waste management system (Number and
type of confined animal (s) : yz51% M'Z'-lie 4 N&a' S
Average animal population on the farm (Number and type of
animal (s) raised) : !LK<'V= Ma"YeO4
Year Production Began: )7 9 Z ASCS Tract No.: b s
Type of Waste Management System Used: Pac4g We 7l,ce lie,
Acres Available for Land App icatpion of Waste: SL4- 2
Owner(s) Signature (s) : ` -X�C , Date: llll lj 3
Date:
(Date Meyer, Serviceman)

State of North Carolina
Department of Environment,
Health and Natur& Resources
Division of Environmental Management
�v
James B. Hunt, Jr., Governor p
Jonathan B. Howes, Secretary ®E �--- f�
A. Preston Howard, Jr., P.E., Director
March 23, 1994
Darrell Stocks
Rt 3 Box 217
Tabor City NC 28463
Dear Mr. Stocks:
This is to inform you that your completed registration form required by the recently
modified nondischarge rule has been received by the Division of Environmental Management
(DEM), Water Quality Section.
On December 10, 1992 the Environmental Management Commission adopted a water
quality rule which governs animal waste management systems. The goal of the rule is for animal
operations to be managed such that animal waste is not discharged to surface waters of the state.
The rule allows animal waste systems to. be "deemed permitted" if certain minimum criteria are
met (15A NCAC 2H .0217). By submitting this registration you have met one of the criteria for
being deemed permitted.
We would like to remind you that existing feedlots which meet the size thresholds listed
in the rule, and any new or expanded feedlots constructed between February 1, 1993 and
December 31, 1993 must submit a signed certification form (copy enclosed) to DEM by
December 31, 1997, New or expanded feedlots constructed after December 31, 1993 must
obtain signed certification before animals are stocked on the farm. Certification of an
approved animal waste management plan can be obtained after the Soil and Water Conservation
Commission adopts rules later this year.
We appreciate you providing us with this information. If you have any question about
the new nondischarge Wile, please contact David Harding at [phone].
Sincerely,
die Steve Tedder, Chief
enc: 99 Water Quality Section
P.O. Box 29535. Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50%recycled/ 10%post-consumer paper