100029_HISTORICAL_20171231

NORTH CAHOLINA
Department of Environmental Qua!

OFVAT ER
�Ot QG
6 7
,❑ NCM�9011. 111�
Marvin Evans
Juniper Creek
6889 Parker Road, NW
Ash NC 28420
Dear Marvin Evans:
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W_ Klimek, P. E., Director
Division of Water Quality
May 1, 2003
Subject: Certificate of Coverage No. AWS100029
Juniper Creek
Swine Waste Collection, Treatment,
Storage and Application System
Brunswick County
On April 28, 2003, the North Carolina General Assembly ratified Senate Bill 733 which directs the
Division of Water Quality (Division) to extend the expiration date of the Swine Waste Operation General
Permit AWG100000. Therefore, the General Permit has been re -issued by the Division to extend the
expiration date to October 1, 2004. During the period of this extension the Division will be working with
all interested parties on the development of a new version of the Non -Discharge General Permit.
In accordance with your application received on February 18, 2003 and in accordance with the directive
of Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to Marvin
Evans, authorizing the operation of the subject animal waste collection, treatment, storage and land
application system in accordance with General Permit AWG100000. The issuance of this 'COC
supercedes and terminates your previous COC Number AWS100029 which expired on April 30, 2003.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Juniper Creek, located in Brunswick County, with an animal capacity of no
greater than an annual average of 3552 Wean to Feeder swine and the application to land as specified in
the facility's .Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or
Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary,
they may be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a
rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until October 1, 2004. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property tights in either real or personal property. *A
E—NR
Non -Discharge Permitting Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
Customer Service Center
An Equal Opportunity Action Employer
Internet httpJ/K2o.enr-gtate.ne.us/ndpu
Telephone [phone] Fax [phone]
Telephone [phone]
50% recycled110% post -consumer paper

Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to -the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility. .
Per NRCS standards a 100 foot separation shall be maintained between water supply wells and any
lagoon or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWW may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Wilmington Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Sue Homewood at [phone] M. 502.
Sincerely,
. Z:2�.
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
Wilmington Regional Office, Water Quality Section
Brunswick County Health Department
Brunswick County Soil and Water Conservation District
Permit File AWS100029
NDPU Files

I?
Nutrient Management Plan For Animal Waste Utilization_
04-30-2001
This plan has been prepared for:
Juniper Creek
Marvin Evans
6889 Parker Road
Ash, NC 28420
[phone]
This plan has been developed by:
Jeffery Brown
DSWC-FRO
225 Green Street
Fayetteville, NC 28301
[phone]
Dev,KP9aiWUre
Type of Plan: Nitrogen Only with Manure Only
Owner/Manager/Producer Agreement
I (we) understand and agree to the specifications and the operation and maintenance
procedures established in this nutrient management plan which includes an animal waste
utilization plan for the farm named above. I have read and understand the Required
Specifications concerning animal waste management that are included with this plan.
��— 54'
Signature (owner) Date
Signature (manager or producer) Date
This plan meets the minimum standards and specifications of the U.S. Department of
Agriculture - Natural Resources Conservation Service or the standard of practices
I
dopted by the Soil and Water Conservation Commission.
Plan Approved By:
ZZ
Te ni al Specialist Signature
RiECEEIVED
Date WATER QUALITY SECTI©I1
i FE8 18 2003
L-
------------------------------------------------------------------------ --------------
886988 Database Version 1.06 Date Printed: 04-30-2001 Cover Page,51-DISCHARGE PERMITTING

Nutrients applied inaccordance with this plan will be supplied from the
following source(s):
Commercial Fertilizer is not included in this plan.
S5
Swine Nursery Lagoon Liquid waste generated 678,432 gals/year by a
3,552 animal Swine Nursery Lagoon Liquid operation. This production
facility has waste storage capacities of approximately 180 days.
Estimated Pounds of Plant Available Nitrogen Generated per Year
Broadcast
1564
Incorporated
2685
Injected
2957
Irrigated
1699
Actual PAN Applied
Year 1
2063
Notes:
In source ID, S means standard source, U means user defined source.
-- ---------------------------------------------------------------------------------
886988 Database Version 1.06 Date Printed: 04-30-2001 Source Page I

Narrative
VA TP is based on zones. Irrigation records need to be kept by zone to match WUP.
--------------------------------------------------------------------------------------
886988 Database Version 1.Ot Date Printed: 04-30-200 i Narrative Page 1

The Waste Utilization table shown below summarizes the waste utilization plan for this operation. This plan provides an estimate of the number of acres of '
cropland needed to use the nutrients being produced. The plan requires consideration of the realistic yields of the crops to be grown, their nutrient requirements,
and proper timing of applications to maximize nutrient uptake.
This table provides an estimate of the amount of nitrogen required by the crop being grown and an estimate of the nitrogen amount being supplied by manure or
other by-products, commercial fertilizer and residual from previous crops. An estimate of the quantity of solid and liquid waste that will be applied on each field
in order to supply the indicated quantity of nitrogen from each source is also included.
A balance of the total manure produced and the total manure applied is included in the table to ensure that the plan adequately provides for the utilization of the
manure generated by the operation. Animal operations that generate liquid waste and utilize waste storage facilities (lagoons or holding ponds) may apply more or
less waste in any given year than is annually generated by the facility. In order to determine whether the plan adequately utilizes the waste produced by the
facility, the storage capacity table included in this plan should be reviewed to ensure that the design capacity of the storage facility is not exceeded during the
planning period.
Depending on the requirements of the crop and the nutrient content of the waste, some nutrients will likely be over or under applied if animal waste is being
utilized. Waste should be analyzed before each application cycle and annual soil tests are required if animal waste is being applied. Soil tests should be used to
balance the nutrient application amounts with the realistic yields of the crop to be grown. Nutrient management plans may require that the application of animal
waste be limited so as to prevent over application of phosphorous when excessive levels of this nutrient are detected in a field.
Waste Utilization Table Year 1
Tract
I Field
Source
1,D.
I Soil Series
"Total
Acre
Use.
Acres
Crop
RYE
RYE
Unit
Applic.
Period
Nitrogen
PA
Nutrient
Req'd
tl
Comm.
Fert.
Nutrient
Applied
I
Ices.
(Ibs/A)
N
Applic.
Method
Manure
PA
Nutrient
Applied
Liquid
Manure
Applied
(acre)
Solid
Matwre
Applied
(acre)
Liquid
Manure
Applied
(Field)
Solid
Manure
Applied
(Field)
N
N
Ibs/A
1000
al/A
tons
1000 gals
tons
493
& 2 - 6
S5
Forestall
1.5
1.5
Small Grain Overseed
1.0
Tons
1011-3/31
50
0
0
hri .
50
20.0
0.0
29.3
0.0
493
& 2 - 6
S5
Forestall
1.5
1.5
Bermuda rass Pasture
6.0
'Pons
3/1-9130
* 180
' 0
0
hri g.
180
71.9
0.0
105.6
0.0
1 493
1-1
S5
Forestall
1.6
1.6
Small Grain Overseed
1.0
Tons
1011-3131
50
0
0
hri s.
50
10.0
0.0
16.2
0.0
493
1-1
S5
Foreston
1.6
1.6
Bermudagrass Pasture
*6.0
Tons
3/1-9130
* 180
0
0
hri g.
180
71.9
0.0
116.4
0.0
493
1-2
S5
Forestall
1.5
1.5
Small Grain Oversced
1.0
Tons
10/1-3/31
50
0
0
Irri .
50
20.0
0.0
29.3
0.0
493
1-2
S5
Foreston
1.5
1.5
BeMlLtdJ r ss Pasture
6.0
Tons
3/129/30
* 180
0
0
Irri .
180
71.9
0.0
105.6
0.0
493
1-3
S5
Forestall
1.5
1.5
Small Grain Overseed
1.0
Tons
1011-3131
50
0
0
Irri .
50
20.0
0.0
29.3
0.0
493
1-3
S5
Forestall
1.5
1.5
Bermuda rass Pasture
6.0
Tons
3/1-9/30
* 180
0
0
hri .
l60
71.9
0.0
105.6
0.0
493
14
S5
Forestall
1 1.51
1.5
Small Grain Overseed
1.0
'Tons
1011-3/31
501
0
0
hri .
50
20.0
0.0
29.3
0.0
--------------------------------------------------- ------------------- ---- - - - - -- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
886988 Database Version 1.06 Date Printed: 04-30-2001 WUT Page l

Waste Utilization Table
Year 1
Tract
Field
Source
I I.D.
I Soil Series
Total
L Acre —. —Acres
Use.
I Crop
RYE
RYE"
Unit
Applic.
Period
Nitrogen
PA
Nutrient
Rcq'd
Comm.
Fert.
Nutrient
Applied
Res.
(Ibs1A)
N
Applic.
Method
Manure
PA
Nutrient
Applied
Liquid
Manure
Applied
(acre)
Solid
Manure
Applied
(acre)
Liquid
Manure
Applied
(Field)
Solid
Manure
Applied
(Field)
N
N
Ibs/A
1000
al/A
tons ,
1000 Pals
tons
493
1-4
SS
I Foreston
1 1.51
1.5
1 Bermudagrass Pasture
6.0
Tons
3/1.9/30
" 1801
0
1 In•i .
180
71.9
0.0
1.05.6
0.0
493
I-5
S5
Foreston
1 1.51
1.5
1 Small Grain Overseed
1.0
Tons
1 1011-3l31
1 501
01
D
1 Irri .
50
20.0
0.0
29.3
0.0
493
1-51
SS
I Foreston
1 1.51
1.5
1 Bermuda rass Pasture
6.0
1 Tons
311-9130
1* 1801
01
D
1 Ini .
180
71.9
0.0
105.6
0.0
Lagoon Liquids
Total Applied, 1000 Sallons
807
Total Produced, 1000 gallons
678
Balance 1000 pallons
-129
Manure Solids
Total Applied, tons
0
Total Produced, tons
0
Balance, tons
1
0
Notes: I. to the tract column, symbol — means leased, otherwise, owned. 2. Symbol * means user entered data.
-----------------------------------------------------------------------------------------------------------------------------------------
886988 Database Version 1.06 Date Printed: 04-30-2001 WUT Page 2

The Irrigation Application Factors for each field in this plan are shown in the following table.
Infiltration rate varies with soils. If applying waste nutrients through an irrigation system, you must
apply at a rate that will not result in runoff. This table provides the maximum application rate per hour
that may be applied to each field selected to receive wastewater. It also lists the maximum application
amount that each field may receive in any one application event.
Irrigation Application Factors
Tract
Field
Soil Series
Application Rate
(inches/hour)
Application Amount
(inches)
493
3 & 2 - 6
Foreston
0.50
0.96
493
!-1
Foreston
0.50
0.96
493
1-2
Foreston
0.50
0.96
493
1 1-3
1 Foreston
0.50
0.96
493
1 1-4
Foreston
0.501
0.96
493 1
-5 1
Foreston
0.501
0.96
--------------------------------------------------------------------------------------
886988 Database Version 1.06 Date Printed: 04-30-2001 IAF Page 1

The following Lagoon Sludge Nitrogen Utilization table provides an estimate of the number of acres needed for
sludge utilization for the indicated accumulation period. These estimates are based on average nitrogen
concentrations for each source, the number of animals in the facility and the plant available nitrogen application
rates shown in the second column.
Lagoon sludge contains nutrients and organic matter remaining after treatment and application of the effluent. At
clean out, this material must be utilized for crop production and applied at agronomic rates. In most cases, the
priority nutrient is nitrogen but other nutrients including phosphorous, copper and zinc can also be limiting. Since
nutrient levels are generally very high, application of sludge must be carefully applied.
Sites must first be evaluated for their suitability for sludge application. Ideally, effluent spray fields should not be
used for sludge application. If this is not possible, care should be taken not to load effluent application fields with
high amounts of copper and zinc so that additional effluent cannot be applied. On sites vulnerable to surface water
moving to streams and lakes, phosphorous is a concern. Soils containing very high phosphorous levels may also be
a concern.
Lagoon Sludge Nitrogen Utilization Table
Crop
Maximum
PA-N Rate
lb/ac
Maximum Sludge
Application Rate
1000 al/ac
Minimum Acres
5 Years Accumulation
Minimum Acres
10 Years Accumulation 1
Minimum Acres
15 Years Accumulation
Swine Nursery Lagoon Sludge - Standard
Corn 120 bu
1.501
13,161
9.041
1&081
27.12
Hay 6 ton R.Y.E.
3001
26.321
4.521
9.041
13.56
Soybean 40 bu
160
14-041
8,481
16.951
25.43
---------------------------------------------------------------------------------------------------
886988 Database Version 1.06 Date Printed: 04-30-2001 Sludge Page 1

The Available Waste Storage. Capacity table provides an estimate of the number of days of storage
capacity available at the end of each month of the plan. Available storage capacity is calculated as the
design storage capacity in days minus the number of days of net storage volume accumulated. The start
date is a value entered by the user and is defined as the date prior to applying nutrients to the first crop in
the plan at which storage volume in the lagoon or holding pond is equal to zero.
Available storage capacity should be greater than or equal to zero and less than or equal to the design
storage capacity of the facility. If the available storage capacity is greater than the design storage
capacity, this indicates that the plan calls for the application of nutrients that have not yet accumulated.
If available storage capacity is negative, the estimated volume of accumulated waste exceeds the design
storage volume of the structure. Either of these situations indicates that the planned application interval
in the waste utilization plan is inconsistent with the structure's temporary storage capacity.
Available Waste Storage Capacity
Source Name
Swine Nursery Lagoon Liquid
Design Storage Capacity (Days)
Start Date
9/30
180
Plan Year
Month
Available Storage Capacity (Days)
1
1
115
1
2
111
1
3
112
1
4
117
1
5
155
1
6
180
1
7
180
1
8
180
1
9
180
1
10
161
1
11
151
1
12
7728
* Available Storage Capacity is calculated as of the end of each month.
---------------------------------------------------------------------------------------
886988 Database Version 1.06 Date Printed: 04-30-2001 Capacity Page 1

Required Specifications For Animal Waste Management
1. Animal waste shall not reach surface waters of the state by runoff, drift,
manmade conveyances, direct application, or direct discharge during
operation or land application. Any discharge of waste that reaches
surface water is prohibited.
2. There must be documentation in the design fold that the producer either
owns or has an agreement for use of adequate land on which to properly
apply the waste. If the producer does not own adequate land to properly
dispose of the waste, he/she shall provide evidence of an agreement with a
landowner, who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner
of the waste production facility to secure an update of the Nutrient
Management Plan when there is a change in the operation, increase in
the number of animals, method of application, receiving crop type, or
available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs
for realistic crop yields based upon soil type, available moisture,
historical data, climatic conditions, and level of management, unless
there are regulations that restrict the rate of applications for other
nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre
per year. Waste may be applied to land eroding at more than 5 tons per
acre per year but less than IO tons per acre per year provided grass filter
strips are installed where runoff leaves the field (see USDA, NRCS Field
Office Technical Guide Standard 393 - Filter Strips).
5. Odors can be reduced by injecting the waste or by disking after waste
application. Waste should not be applied when there is danger of drift
from the land application field.
6. When animal waste is to be applied on acres subject to flooding, waste
will be soil incorporated on conventionally tilled cropland. When waste is
applied to conservation tilled crops or grassland, the waste may be
broadcast provided the application does not occur during a season prone
to flooding (see "Weather and Climate in North Carolina" for guidance).
-------------------------------------------------------------
886988 Database Version 1.06 Date Printed: 04-30-2001 Specification Page 1

7. Liquid waste shall be applied at rates not to exceed the soil infiltration
rate such that runoff does not occur offsite or to surface waters and in a
method which does not cause drift from the site during application. No
ponding should occur in order to control odor and flies.
S. Animal waste shall not be applied to saturated soils, during rainfall
events, or when the soil surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a
manner that the crop is not covered with waste to a depth that would
inhibit growth. The potential for salt damage from animal waste should
also be considered.
10. Nutrients from waste shall not be applied in fall or winter for spring
planted crops on soils with a high potential for leaching. Waste/nutrient
loading rates on these soils should be held to a minimum and a suitable
winter cover crop planted to take up released nutrients. Waste shall not
be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply
with the following: The outer perimeter of the land area onto which
waste is applied from a lagoon that is a component of a swine farm shall
be at least 50 feet from any residential property boundary and canal.
Animal waste, other than swine waste from facilities sited on or after
October 1, 1995, shall not be applied closer that 25 feet to perennial
waters.
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other
than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and
public right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways,
or wetlands by a discharge or by over -spraying. Animal waste may be
applied to prior converted cropland provided the fields have been
approved as a land application site by a "technical specialist". Animal
waste shall not be applied on grassed waterways that discharge directly
--------------------------------------- ------ - --------------------------
886988 Database Version 1.06 Date Printed: 04-30-2001 Specification Page 2

into water courses, and on other grassed waterways, waste shall be
applied ar agronomic rates in a manner that causes not runoff or drift
from site.
16. Domestic and industrial waste from washdown facilities, showers, toilets,
sinks, etc., shall not be discharged into the animal waste management
system.
17. A protective cover of appropriate vegetation will be established on all
disturbed areas (lagoon embankments, berms, pipe runs, etc.). Areas
shall be fenced, as necessary, to protect the vegetation. Vegetation such
as trees, shrubs, and other woody species, etc., are limited to areas where
considered appropriate. Lagoon areas should be kept mowed and
accessible. Berms and structures should be inspected regularly for
evidence of erosion, leakage, or discharge.
18. If animal production at the facility is to be suspended or terminated, the
owner is responsible for obtaining and implementing a "closure plan"
which will eliminate the possibility of an illegal discharge, pollution, and
erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected
on a regular basis to prevent breakdowns, leaks, and spills. A regular
maintenance checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other
crops for direct human consumption. However, if animal waste is used
on crops for direct human consumption, it should only be applied
pre -plant with no further applications of animal waste during the crop
season.
21. Highly visible markers shall be installed to mark the top and bottom
elevations of the temporary storage (pumping volume) of all waste
treatment lagoons. Pumping shall be managed to maintain the Iiquid
level between the markers. A marker will be required to mark the
maximum storage volume for waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested
at least annually at crop sites where waste products are applied.
------------------------- --------------------------------------------------------------
886988 Database Version 1.06 Date Printed: 04-30-2001 Specification Page 3

Nitrogen shall be the rate -determining nutrient, unless other restrictions
require waste to be applied based on other nutrients, resulting in a lower
application rate than a nitrogen based rate. Zinc and copper levels in the
soils shall be monitored and alternative crop sites shall be used when
these metals approach excessive levels. pH shall be adjusted and
maintained for optimum crop production. Soil and waste analysis
records shall be kept for a minimum of five years. Poultry dry waste
application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a
minimum of five years.
23. Dead animals will be disposed of in a manner that meets North Carolina
regulations.
----------------------------------------------- --- --------------------------
886988 Database Version 1.06 Date Printed: 04-30-2001 Specification Page 4

Crop Notes
The following crop note applies to feld(s): I & 2 - 6, 1-1, 1-2, 1-3, 14, 1-5
Small Grain: CP, Mineral Soil, low -leachable
In the Coastal Plain, oats and barley should be planted from October 15-October 30; and rye from
October 15-November 20. For barley, plant 22 seed/drill row foot and increase the seeding rate by 5% for
each week seeding is delayed beyond the optimum time. See the seeding rates table for applicable
seeding rate modifications in the current NCSU "Small Grain Production Guide". Also, increase the
initial seeding rate by at least 10% when planting no -till. Oats should be planted at 2 bushels/acre and
rye at 1-1 1/2 bushels/acre. Plant all these small grains at 1-1 1/2" deep. Adequate depth control is
essential. Review the NCSU Official Variety "green book" and information from private companies to
select a high yielding variety with the characteristics needed for your area and conditions. Apply no more
than 30 lbs/acre N at planting. Phosphorus and potash recommended by a soil test can also be applied at
this time. The remaining N should be applied during the months of February -March.
The following crop note applies to field(s): I & 2 - 6, 1-1, 1-2, 1-3, 1-4, 1-5
Bermudagrass CP, Mineral Soil, Poorly Drained to Somewhat Poorly Drained.
Adaptation: Effective artificial drainage MUST be in place to achieve Realistic Yield Expectations
provided for these soils.
In the Coastal Plain, hybrid bermudagrass sprigs can be planted Mar. I to Mar. 31. Cover sprigs I" to 3"
deep (1.5" optimal). Sprigs should be planted quickly after digging and not allowed to dry in sun and
wind. For Coastal and Tifton 78 plant at least 10 bu/ac in 3' rows, spaced 2' to 3' in the row. Generally a
rate of 30 bu/ac is satisfactory to produce full groundcover in one or two years under good growing -
conditions. Tifton 44 spreads slowly, so use at least 40 bu/ac in 1.5' to 2' rows spaced 1' to 1.5' in row.
For broadcast/disked-in sprigs use about 60 bu/ac. Soil test for the amounts of lime, phosphorus,
potassium and micronutrients to apply preplant and for annual maintenance. Apply 60 to 100 lb/ac N in
the establishment year in split applications in April and July. For established stands apply 180 to 240
lb/ac N annually in split applications, usually in April and following the first and second hay cuts.
Reduce N rates by 25% for grazing. Refer to NCSU Technical Bulletin 305 Production and Utilization
of Pastures and Forages in North Carolina for more information or consult your regional agronomist or
extension agent for assistance.
--------------------------------------------------------------------------------------
886988 Database Version 1.0( Date Printed: 04-30-2001 Crop Note Page 1

I I I�N
s
---Vo
THRUST BLOCK DETAIL
NTS
NSTRULImm HNC
L B' A S' PTO PIPE 9$AI1 B1 B11IOND A WXW1711 OF 24 INCHES WWW
GROUND SURFACE, 4' ®AIL HE $IIRRD A MOMM OF SO INCHES
P- ALL PIPE MUM BE CUSS 160 CAM= M PVC. THE NIIPPLY MM
BHLL. Ra' 4-n= IN DIL LID THE LATERALS SNAIL OR IC 0. & 4 INCH DLL
' ,11E Eu9. EECi, TR[d6. WAND MNB, NM HKAll RE CLASS 200.
4. SUCTION PIPE ON PUMP
BAILPTCNR• HAINTANM AT A DEPTH or 16 DtCH�
MDW WATER SURFACE TMUGH U$1 OF A nDATATION D1YIC)R
6 SPISMS R RRQ 1NM➢ 1ACKWAY MIX iNDMM No. or
0. H®GATION PUIHs ®i1L @ R>RtE[1<7 MODEL R 1 1/2TPIL 10 W tRIIGILt PHASE
I16�JLH! BHAfl iUt T$DODm TD 0.I4".
7. USCOAmoN PUMP HHLL HE LOCATED ON 70P Of DUE WAIL. HOUGATION
PIPE cam= FmoM PUMP SHALL HOT BE BUR® IN DOR WAIL. PIP$
SHALL HA RON TO A HTDRANT A7 THE ➢nR BASE TRICH SIR=
D1! CONNECTED To 7$E SUPPLY 1LNIS.
0. A TOTAL QF Qg A!R asQURED, SENNWOER MODEL ?MKID I-1'H
1/4' NOZE1i OP>�171HQ lb PHL 19 GPiI O$ 1pUlY.
E. A I" WR&9T=uTE QUICK COUPLED WTTB RUSHER COVE$ (OR NQULV.) SHALL
OR ISED 80 AT AM SPRINII,1121 CONNECTION . ► RUB= COVER SHALL BE
USED TO PwVzcT THE QUICK COHPIER
10. EXAM MM CONNECTION TYPE SNAIL. HE LOT UP 7o TSE DWALUX
BASED ON THE NEEDS or THE GRomm kicommID USING E OR B -Bow
CQNNEI.TIONS FOR LATERAL PROTECTION.
LL TH$OST HIDCKS VOL BE PROVIDED AT ALL ILLS, SKIMS, TEES AND VALVES.
I2 PRESSURE GAWK AT 7N1 PUMP BRAIA, al OLYMM FILLED 70 X== THAT
WASTEWATER DOW NOT DAMAGE IT.
I& RUCTION PIPE ON THE PUMP SHALL BE S-DICH DI 11111LIM- . SONS KIND Or
STRAnNED Emu BE INSTAlliD ON THE END Of THE SUCTIGN FLPK A NOT
VALVE CAN BE AN OpTLONAL IMOL
14, SOME KDW OF FROM OVER SHALT. DK INSTALLED ON THE SIX'MN 633E
OF THE PUMP. TYPE AND 112AND S11AIL OR 12rr UP 7O THE CONTRAMIL
IR Am REIJIDF/VACUUM Emu VALVES GRAIL RE DWALLED AT THE RICH An
LOT YO O► THE SYSTEM AND AT THE ENDS OF THE SUPPLY ILNC
AgRbL STATE OF NORTH CAROLINA
IlWANHmM Or EEYEIOml= m'lm A= EATVIAL EE6 ujm
umof =x or EOE. mm TAT= coxow&mg
AEUMM MOMM OFFICE
v Fom" M" AEEEUE = Era "a (mo niu
vz i=
1:
Y�
gg1�
i
1
3
EE1 >s ErC!as sAe W E� EO• Qa>m '
a v EmaEv tE� _
i
i
JUNIPER CREEK
IRRIGATION DESIGN
BRUNSWICK COUNTY
I
1 6-ni STSSL PIPE SLKKVE
OR 6-II PVC PIPE PAINTED i
DITCH CROSSING DETAIL
NTS
LEGEND....... ... .......... ...... —... _.. _ ................_- _ . __._ ..__ _
- - FIELD BOUNDARY
- - - - DITCH BUFFER
4-INCH STAIN PVC SUPPLY LINE
9-INCH PVC LATERAL LINE
2-INCH PVC LATERAL LINE
x SPRINKLER
x GATE OR GLOBE VALVE
0 ZONE IDENTIFICATION NO.
p TRAVERSE SURVEY POINT
9 TEMPORARY BENCHMARK
I'Aotoe M W y
ENA1a 1 m- IOC
® n
mm
EE6! EA N 1
A mum Y—M

-FLAN OF ACTION (POA) FOR HIGH FREEBOARD AT ANIMAL FACILITIES
Facility Number:`'°; . r County: HYcc�.=l��
Facility Name:
Certified Operator Name: Air, r-U ! "i J-' U C,- N S Operator # c) ?l /
Current liquid level(s) in inches as measured from the current liquid level in the lagoon to the
lowest point on the top of the dam for lagoons without spillways; and from the current liquid level
in the lagoon to the bottom of the spillway for lagoons with spillways.
Structure 1 Structure 2 Structure 3 Structure 4 Structure 5 Structure 6
Lagoon Name/Identifier (ID):
Spillway (Yes or No): _ zt/
Level (inches):
2. Check all applicable items
Liquid level is within the designed structural freeboard elevations of one or more structures. Five
and 30 day Plans of Action are attached. Hydraulic and agronomic balances are within
acceptable ranges.
X— Liquid level is within the 25 year 24 hour storm elevations for one or more structures. A 30 day
Plan of Action is attached. Agronomic balance is within acceptable range.
Waste is to be pumped and hauled to off site locations. Volume and PAN content of waste to
pumped and hauled is reflected in section III tables. Included within this plan is a list of the
proposed sites with related facility number(s), number acres and receiving crop information.
Contact and secure approval from the Division of Water Quality prior to transfer of waste
to a site not covered in the facility's certified animal waste management plan.
Operation will be partially or fully depopulated.
- attach a complete schedule with corresponding animal units and dates for depopulation
- if animals are to be moved to another permitted facility, provide facility number, lagoon
freeboard levels and herd population for the receiving facility
3. Earliest possible date to begin land application of waste: AA-Q
I hereby certify that I have reviewed the information listed above and included within the attached Plan
of Action, and to the best of my knowledge and ability, the information is accurate and correct.
yl/Ay 4EM1W
Facility Owner/Manager (print)
n .cs
Facility Owner/Manager (signature)
PoA Cover Page 2I21/00
Phone:
Date: —'
SEP 0 8 2006
� D5l .

PLAN OF ACTION (PoA) FOR HIGH FREEBOARD AT ANIMAL FACILITIES
30 DAY DRAW DOWN PERIOD
I. TOTAL PAN TO BE LAND APPLIED PER WASTE STRUCTURE
1. Structure Namelldentifier (ID): 10 - 29 lagoon
2. Current liquid volume in 25 yr.124 hr. storm storage & structural freeboard
a. current liquid level according to marker 15.0 inches
b. designed 25 yr.124 hr. storm & structural freeboard 20.0 inches
c. line b - line a (inches in red zone) = 5.0 inches
d. top of dike surface area according to design
(area at below structural freeboard elevation) 27606 ftz
e. line c112 x line d x 7.48 gallons/W 86039 gallons
3. Projected volume of waste liquid produced during draw down period
f. temporary storage period according to structural design 180 days
g. volume of waste produced according to structural design 260231 ft3
h. current herd # 3552 certified herd #1 3552
actual waste produced = current herd # x line g =
certified herd #
i. volume of wash water according to structural design
j. excess rainfall over evaporation according to design
k. (lines h + i + j) x 7.48 x 30 days/line f=
4. Total PAN to be land applied during draw down period
I. current waste analysis dated 1 8/25/2006
m. ((lines e + k)11000) x line I =
REPEAT SECTION I FOR EACH WASTE STRUCTURE ON SITE.
(Click on the next Structure tab shown below)
26023 ft'
®ft3
17325 ft3
54041 gallons
0.79 Ibs/1000 gal.
110.7 lbs. PAN
PoA (30 Day) 2/21/00

y_r �
PLAN OF ACTION (PoA) FOR HIGH FREEBOARD AT ANIMAL FACILITIES
30 DAY DRAW DOWN PERIOD
I. TOTAL PAN TO BE LAND APPLIED PER WASTE STRUCTURE
1. Structure Name/identifier (ID): 10 - 29 lagoon
2. Current liquid volume in 25 yr.124 hr. storm storage & structural freeboard
a. current liquid level according to marker 15.0 inches
b. designed 25 yr.124 hr. storm & structural freeboard 20.Q inches
c. line b - line a (inches in red zone) = 5.0 inches
d. top of dike surface area according to design
(area at below structural freeboard elevation) 27606 ftz
e. line c112 x line d x 7.48 gallons/W 86039 gallons
3. Projected volume of waste liquid produced during draw down period
f. temporary storage period according to structural design 180 days
g. volume of waste produced according to structural design 26023 Jft3
h. current herd # 3552 certified herd # 3552
actual waste produced = current herd # x line g =
certified herd #
i. volume of wash water according to structural design
j. excess rainfall over evaporation according to design
k. (lines h + i + j) x 7.48 x 30 days/line f=
4. Total PAN to be land applied during draw down period
I. current waste analysis dated 1 8/25/2006
m. ((lines e + k)11000) x line I =
REPEAT SECTION I FOR EACH WASTE STRUCTURE ON SITE.
(Click on the next Structure tab shown below)
26023 ft'
© ft3
17325 ft3
54041 gallons
0.79 lbs11000 gal.
110.7 lbs. PAN
PoA (30 Day) 2/21100

II. TOTAL POUNDS OF PAN STORED WITHIN STRUCTURAL FREEBOARD AND/OR 25 YR.124
HR. STORM STORAGE ELEVATIONS IN ALL WASTE STRUCTURES FOR FACILITY
1.
Structure ID: 10 - 29 lagoon
line m = 110.7 lb PAN
2,
Structure ID:
line m =
lb PAN
3:
Structure ID:
line m =
lb PAN
4.
Structure ID:
line m =
lb PAN
5.
Structure ID:
line m =
lb PAN
6.
Structure ID:
line m =
lb PAN
n.lines 1+2+3+4+5+6= 110.7lbPAN
III. TOTAL PAN BALANCE REMAINING FOR AVAILABLE CROPS DURING 30 DAY DRAW DOWN
PERIOD. DO NOT LIST FIELDS TO WHICH PAN CANNOT BE APPLIED DURING THIS 30 DAY PERIOD.
o. tract #
p. field #
q. crop
r. acres
s. remaining IRR
2 PAN balance
(lb/acre)
t. TOTAL PAN
BALANCE FOR
FIELD (Ibs.)
column r x s
u. application window'
493
z - 1
bermuda
1.601
88.20
141.1
311 - 9/30
493
z - 2
bermuda
1.50
93.70
140.6
3/1 - 9130
493
z - 3
bermuda
1.50
82.40
123.6
3/1 - 9/30
'State current crop ending application date or next crop application beginning date for available
receiving crops during 30 day draw down period.
v. Total PAN available for all fields (sum of column t) = 405.3 lb. PAN
IV. FACILITY'S PoA OVERALL PAN BALANCE
PoA (30 Day) 2/21100

w. Total PAN to be land applied (line n from section ll) = 110.7 lb. PAN
x. Crop's remaining PAN balance (line v from section III) = 405.3 lb. PAN
y. Overall PAN balance (w - x) _ -295 lb. PAN
Line y must show as a deficit. If line y does not show as a deficit, list course of action here including pump and
haul, depopulation, herd reduction, etc. For pump & haul and herd reduction options, recalculate new PAN
based on new information. If new fields are to be included as an option for lowering lagoon level, add these
fields to the PAN balance table and recalculate the overall PAN balance. If animal waste is to be hauled to
another permitted facility, provide information regarding the herd population and lagoon freeboard levels at the
receivinq facility.
has several other fields with PAN left on bermuda, that was not needed for this 30 day POA.
PoA (30 Day) 2/21/00

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
May 1, 2003
Marvin Evans
Juniper Creek
6889 Parker Road, NW
Ash NC 28420
Alan W. Klimek, P. E., Director
Division of Water Quality
xo -zg
Subject: Certificate of Coverage No. AWS100029
Juniper Creek
Swine Waste Collection, Treatment,
Storage and Application System
Brunswick County
Dear Marvin Evans:
On April 28, 2003, the North Carolina General Assembly ratified Senate Bill 733 which directs the
Division of Water Quality (Division) to extend the expiration date of the Swine Waste Operation General
Permit AWG100000. Therefore, the General Permit has been re -issued by the Division to extend the
expiration date to October 1, 2004. During the period of this extension the Division will be working with
all interested parties on the development of a new versioAoft Non -Discharge General Permit.
In accordance with your application received on Februa00 and in accordance with the directive
of Senate Bill 733, we are hereby forwarding to you t 'ate of Coverage (COC) issued to Marvin
Evans, authorizing the operation of the subject waste collection, treatment, storage and land
application system in accordance with Gener P AWGL00000. The issuance of this COC
supercedes and terminates your previous CO�fi AWS100029 which expired on April 30, 2003.
This approval shall consist of the operation'k 's system including, but not limited to, the management
of animal waste from the Juniper Creek, located in Brunswick County, with an animal capacity of no
greater than an annual average of 3552 Wean to Feeder swine and the application to land as specified in
the facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or
Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary,
they may be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a
rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance unti October 1, 2004. Pursuant to this COC, you
are authorized and required to operate the system in conformity
wit the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the,Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property. T..i
NL M
Non -Discharge Permitting Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
Customer Service Center
An Equal Opportunity Action Employer
Internet http://h2o.enr.state.ne.us/ndpu
Telephone [phone] Fax [phone]
Telephone [phone]
50% recycled/10% post -consumer paper

Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per NRCS standards a 100 foot separation shall be maintained between water supply wells and any
lagoon or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A namelownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Wilmington Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Sue Homewood at [phone] ext. 502.
Sincerely,
zdel-
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
Wilmington Regional Office, Water Quality Section
Brunswick County Health Department
Brunswick County Soil and Water Conservation District
Permit File AWS100029
NDPU Files

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
SWINE WASTE OPERATION GENERAL PERMIT
This permit shall be effective from the date of issuance until October 1, 2004. Holders of
Certificates of Coverage (COC) under this permit shall comply with 'the following specified conditions
and limitations:
I. PERFORMANCE STANDARDS
1. The animal waste collection, treatment, storage and application system permitted under
this permit shall be effectively maintained and operated as a non -discharge system to
prevent the discharge of pollutants to surface waters, wetlands, or ditches. Application of
waste at agronomic rates to terraces and grassed waterways is acceptable in accordance
with Natural Resources Conservation Service (MRCS) Standards. Facilities which are in
compliance with their CAWMP and this permit, which unintentionally discharge as a
result of a storm event greater than the 25-year, 24-hour storm, will not be considered to
be in violation of this permit.
2. The CAWMP is hereby incorporated by reference into this general permit. New or
expanding farms are required to be certified prior to the stocking of animals. The
CAWMP must be consistent with all applicable statutes, rules and standards in effect at
the time of siting, design and certification of the facility. Any violation of the CAWMP
shall be considered a violation of this general permit and subject to enforcement actions.
A violation of the General Permit may result in the Permittee having to take immediate or
long term corrective action(s) as required by the Division of Water Quality. These
actions may include modifying the CAWMP, ceasing land application of waste, or
removing animals from the farm.
3. The facility may not be expanded above the capacity shown in the COC until a new COC
reflecting the expansion has been issued.
4. A copy of this General Permit, COC, certification forms, .lessee and landowner
agreements, and the CAWMP shall be readily available at the farm (stored at places such
as the farm residence, office, outbuildings, etc.) where animal waste management
activities are being conducted for the life of this permit. These documents shall be kept
in good condition and records shall be maintained in an orderly fashion.
5. For all new and expanding operations, no collection or storage facilities may be
constructed in a 100-year flood plain.
6. Existing swine dry lots may remain in wetlands as long as the wetlands uses are not
removed or degraded as a result of the swine. The swine however may not be confined
within 100 feet of an adjacent stream or a seasonally -flooded area The swine also must
not cause a loss of more than 101/10 of the existing tree canopy. Where trees do not exist,
the area must be managed to include crop rotation.

II. OPERATION AND MAINTENANCE REQUIREMENTS
The collection, treatment, and storage facilities, and land application equipment and fields
shall be maintained at all times and properly operated.
2. A vegetative cover shall be maintained on: all land application fields and buffers in
accordance with the CAWMP. No waste may be applied upon fields not included in the
CAWMP.
3. Lime must be applied, as needed, to maintain soil pH in the optimum range for crop
production.
4. Land application rates shall be in accordance with the CAWMP. In no case shall land
application rates exceed the Plant Available Nitrogen rate for the receiving crop or result
in runoff during any given application.
5. Application of animal waste onto land which is used to grow crops for direct human
consumption (e.g., strawberries, melons, lettuce, cabbage, apples, etc.) shall not occur
following the planting of the crop or at any time during the growing season, or in the case
of fruit bearing trees, following breaking dormancy. Application of animal wastes shall
not occur within 30 days of the harvesting of fiber and food crops for direct human
consumption that undergo further processing.
6. If manure or sludges are applied on conventionally tilled bare soil, the waste shall be
incorporated into the soil within two (2) days after application on the land. This
requirement does not apply to no -till fields, pasture, or fields where crops are actively
growing.
7. Domestic and/or industrial wastewater from showers, toilets, sinks, etc. shall not be
discharged into the animal waste collection, treatment, storage and application system.
Washdown of stock trailers, owned by and used to transport animals to and from this
farm only, will be permissible as long as the system can accommodate the additional
volume. Only those detergents and disinfectants that are labeled by the manufacturer as
readily biodegradable may be utilized.
8. Disposal of dead animals shall be done in accordance with the North Carolina
Department of Agriculture and Consumer Services (NCDACS) - Veterinary Division's
regulations.
9. Unless accounted for in temporary storage volume, all uncontaminated runoff from the
surrounding property and buildings shall be diverted away from the animal waste lagoons
and storage ponds to prevent any unnecessary addition to the liquid volume in the
structures.
10. A protective vegetative cover shall be established and maintained on all lagoon/storage
pond embankments (outside toe of embankment to maximum pumping elevation), berms,
pipe runs, and surface water diversions. Trees, shrubs, and other woody vegetation shall
not be allowed to grow on the lagoon/waste storage pond embankments. All trees shall
be removed in accordance with good engineering practices. Lagoon/waste storage pond
areas shall be accessible, and vegetation shall be kept mowed.
11. At the time of sludge removal from a lagoon, the sludge must be managed in accordance
with a CAWMP. When removal of sludge from the lagoon is necessary, provisions must
be taken to prevent damage to lagoon dikes and liners.
2

-12. Lagoons/storage ponds shall be kept free of foreign debris including, but not limited to,
tires, bottles, light bulbs, gloves, syringes or any other solid waste.
13. The facility must have one of the following items at all times (a) adequate animal waste
application and Dandling equipment, (b) a lease, or other written agreement, for the use of
the necessary equipment, (c) a contract with a third party applicator capable of providing
adequate waste application, or (d) a contract for the purchase of the equipment.
Equipment shall be capable of meeting pennit condition II (4).
III. MONITORING AND REPORTING REQUIREMENTS
An inspection of the waste collection, treatment, and storage structures and runoff control
measures shall be conducted at a frequency to insure proper operation but at least
monthly and after storm events. For example, lagoons, storage ponds, and other
structures should be inspected for evidence of erosion, leakage, damage by animals or
discharge. Any major structural repairs (to lagoons or waste storage ponds) must have
written documentation from a technical specialist certifying proper design and
installation. However, if a piece of equipment is being replaced with a piece of
equipment of the identical specifications, no technical specialist approval is necessary
[i.e. piping, reels, valves, pumps (if the GPM capacity is not being increased or
decreased), etc.].
2. If not already installed at this facility, a waste -level gauge to monitor waste levels shall be
installed within 60 days of issuance of the COC under this general permit. This gauge
shall have readily visible permanent markings indicating the maximum liquid level at the
top of the temporary liquid storage volume, minimum liquid level at the bottom of the
temporary liquid storage volume, top of the dam elevations. Where storage ponds are
utilized, only a gauge indicating the maximum liquid level at the top of the temporary
liquid storage volume and top of dam elevations need be installed. Caution must be taken
not to damage the integrity of the liner when installing the gauge. Waste lagoon and
storage pond levels shall be recorded weekly on forms supplied or approved by the
DWQ. For level gauges already installed, the gauge shall have at a minimum: readily
visible permanent markings indicating the maximum liquid level at the top of the
temporary liquid storage volume and minimum liquid level at the bottom of the
temporary liquid storage volume.
3. A representative Standard Soil Fertility Analysis, including pH, copper, and zinc, shall be
conducted annually on each application field receiving animal waste. The results of these
tests shall be maintained on file by the Permittee for a minimum of three years and shall
be made available to the DWQ upon request.
4. An analysis of the animal waste shall be conducted as close to the time of application as
practical and at least within 60 days (befdre or after) of the date of application. This
analysis shall include the following parameters:
Nitrogen Zinc
Phosphorous Copper
S. Records, including land application event(s) and removal of solids to an off -site
location(s) records, shall be maintained by the Permittee in chronological and legible
form for a minimum of three years. These records shall be maintained on forms provided
or approved by the DWQ and shall be readily available for inspection.
3

6. Regional Notification:
The Permittee shall report by telephone to the appropriate Regional Office as soon as
possible, but in no case more than 24 hours following first knowledge of the occurrence
of any of the following events:
a. Failure of any component of the animal waste collection, treatment, storage and land
application system resulting in a discharge to surface waters.
b. Any failure of the animal waste treatment and disposal system that renders the facility
incapable of adequately receiving, treating or storing the animal waste and/or sludge.
c. A spill or discharge from a vehicle transporting animal waste or sludge to the , land
application field which results in, a discharge to surface waters or an event that poses
a serious threat to surface waters.
d. Any deterioration or leak in a lagoon/storage pond that poses an immediate threat to
the environment.
e. Failure to maintain storage capacity in a lagoon/storage greater than or equal to that
required in Condition V (3) of this General Permit.
f. Overapplying animal waste either in excess of the limits set out in the CAWMP or
where runoff enters surface waters.
g. Any discharge that bypasses a lagoon/storage pond resulting in a discharge to surface
waters or that poses a serious threat to the environment.
For any emergency which requires immediate reporting after normal business
hours, please contact the Division of Emergency Management at 1-800-858-0368.
The Permittee shall also file a written report to the appropriate DWQ Regional Office of
the occurrence within 5 calendar days following first knowledge of the occurrence. This
report shall outline the actions taken or proposed to be taken to correct the problem and to
ensure that the problem does not recur. The requirement to file a written report may not
be waived by the DWQ Regional Office.
IV. INSPECTIONS
Any duly authorized officer, employee, or representative of the DWQ may, upon
presentation of credentials and in accordance with reasonable and appropriate biosecurity
measures, enter and inspect any property, premises or place on or related to the collection,
treatment, storage and land application system at any reasonable time for the purpose of
determining compliance with this permit; may inspect and obtain a copy of any records
that must be kept under the terms and conditions of this permit; and may obtain samples
of the animal waste, groundwater, soil, plant tissue, or surface water.
V. GENERAL CONDITIONS
I. The issuance of a COC under this permit shall not relieve the Permittee of the
responsibility for damages to surface waters or ground waters resulting from the animal
operation.
2. The Permittee shall designate a certified animal waste management system operator to be
in charge (01C) of the animal waste management system. The animal waste management
system shall be operated by the OIC or a person under the OIC's supervision.
0

The maximum waste level in lagoons/storage ponds shall not exceed that specified in the
CAWMP. At a minimum, maximum waste level for lagoons/storage ponds must not
exceed the level that provides adequate storage to contain the 25-year, 24-hour storm
event plus an additional 1 foot of structural freeboard. In addition to the above
requirements, for new and expanding farms with lagoon designs completed after
September 1, 1996, storage must also be provided for the heavy rainfall factor for lagoons
without an outside drainage area.
In the case of lagoons/storage ponds in series that are gravity fed, the 25-year, 24-hour
storm event and/or the heavy rainfall factor storage requirements for the system may be
designed into the lowest lagoon/storage pond in the system. However, adequate
freeboard must be designed into each of the upper lagoons/storage ponds to allow
sufficient storage to prevent the waste level from raising into the structural freeboard
while the storm water is draining into the lowest lagoon in the system.
4. Should the DWQ have good reason to believe that any activities conducted pursuant to
this permit may cause or contribute any waste, directly or indirectly, to be intermixed
with the waters of the State, the DWQ may require any monitoring (including but not
limited to groundwater, surface water, animal waste, sludge, soil and plant tissue)
necessary to determine the source, quantity, quality, and effect of such waste upon the
waters of the State. Such monitoring, including its scope, frequency, duration and any
sampling, testing, and reporting systems, shall meet all applicable Environmental
Management Commission requirements. "Good Reason" may be based on the findings of
a related Federal, State, Commission or DENR authorized study or report, or other
evidence showing that violations of State water quality standards or other applicable
environmental standards have occurred or -may occur.
5. Failure to abide by the conditions and limitations contained in this permit, the facility's
CAWMP and/or any COC issued under this permit may subject the Permittee to an
enforcement action by the DWQ in accordance with North Carolina General Statutes and
may include the requirement to obtain an individual non -discharge permit and/or the
modification of the animal waste management system
6. The issuance of a COC under this permit does not excuse the Permittee from the
obligation to comply with all applicable statutes, rules, regulations, or ordinances (local,
state, and federal).
7. if animal production ceases, the Permittee shall close the lagoons/storage ponds in
accordance with Natural Resource Conservation Service (NRCS) lagoon/storage pond
closure standards or develop and implement an animal waste management plan in
accordance with NRCS standards. Closure shall also include notifying the DWQ and
submittal of the Animal Waste Storage Pond and Lagoon Closure Report Form to DWQ-
Water Quality Section- Non -Discharge Branch within 15 days of completion of closure.
8. The annual permit fee shall be paid by the Permittee within thirty (30) days after being
billed by the Division. Failure to pay the fee accordingly constitutes grounds for
revocation of the COC granting coverage under this General Permit.
9. Failure of the Permittee to maintain, in full force and effect, lessee and landowner
agreements which are required in the CAWMP, shall constitute grounds for revocation of
the COC granting coverage under this General Permit.
10. This permit allows for the distribution of manure up to 4 cubic yards per visit to
individuals for personal use.
k

11. The Groundwater Compliance Rnnndary for the. disco gal iysk--m c'mv:f "iw.(cd Alct
December 31, 1983, is established at either (1) 250 feet from the waste structures and
from the waste disposal area, or (2) 50 feet within the property boundary, whichever is
closest to the waste structures and the waste disposal area. If this facility was constructed
prior to December 31, 1983, the Compliance Boundary is established at either (1) 500
feet from the waste disposal area, or (2) at the property boundary, whichever is closest to
the waste disposal area. An exceedance of Groundwater Quality Standards at or beyond
the Compliance Boundary is subject to the requirements of 15A NCAC 2L and the
Division in addition to the penalty provisions applicable under the North Carolina
General Statutes.
This General Permit issued the V day of May, 2003.
NORTH CAROLINA ENVIRONMENTAL MANAGEMENT COMMISSION
441,011." K4�lk
Alan W. Klimek, .E., Director
Division of Water Quality
By Authority of the Environmental Management .Commission
y
Swine Waste General Permit Number AWG100000
r�

W11
W A PpMichael F. Easley. Governor
OWilliam G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E. Director
a.� Division of Water Quality
July 23, 2003
Marvin Evans
6889 Parker Road NW
Ash, NC 28420
Subject: Rescission of Notice of Violation 1
Issuance of Notice of Deficiency
Juniper Creek
Facility # 10-29
Brunswick County
Dear Marvin Evans:
Thank you for your recent submittal of the information requested in our letter dated April 15,
2003. We greatly appreciate the effort that you made in compiling this information and sending
it to our Wilmington Regional Office by the date required. We also appreciate the fact that you
reported the problem with high freeboard to our staff as required by your permit and worked with
our staff to manage the problem once it occurred.
Upon review and consideration of the information submitted, the Wilmington Regional Office has
determined that no further compliance/enforcement actions will be taken by the Division for
these high freeboards.
Also, based on your actions to properly operate your facility, the Division of Water Quality
hereby rescinds the Notice of Violation that was issued to you on April 15, 2003 and replaces it
with this Notice of Deficiency.
In the future, please continue to evaluate ways to maintain freeboard levels in the required range.
These methods include, but are not limited to, water conservation practices, adding additional
application sites, updating your cropping systems, adding additional and/or more flexible
application equipment, and maintaining the lagoon levels at the lowest allowable and appropriate
levels throughout the year. Our staff looks forward to continuing to work with you and your
Technical Specialist to evaluate and implement any needed changes to your system.
Customer Service: Mailing Address: -- - - --- -- - - -- telephone: [phone] -
1 800 623-7748 1617 Mail Service Center Fax: [phone]
Raleigh, NC 27699-1617 State Courier #52-01-01
An Equal Opportunity 1 Affirmative Action Employer
50% recycled / 10% post -consumer paper
http://h2o.enr.state.ne.us
aM.
1NME
Location: -- - - - - -.
512 N. Salisbury St.
Raleigh, NC 27699-1617

Inadequate Freeboard
Marvin Evans
July 23, 2003
Page 2
Thank you again for your cooperation. If you have any questions, please do not hesitate to
contact the staff of our Wilmington Regional Office at 910-395-3900.
Sincerely,
Rick Shiver
Water Quality Regional Supervisor
CC: Kraig Westerbeek, Murphy -Brown, LLC
Mamie Caison, Brunswick County Soil and Water Conservation District
John College, DSWC
-Wilmington Files 10-29
4Non-Discharge Compliance and Enforcement Unit
Central Files

April 16, 2003
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Marvin Evans
6889 Parker Road, NW
Ash NC 28420
SUBJECT: Notice of Violation
Request for Information
Inadequate Freeboard
Juniper Creek
# 10-29
Brunswick County
Dear Sir or Madam:
Michael F. Easley
Governor
William G. Ross Jr., Secretary
Department of Environment and Natural Resources
Alan W. Klimek, P.E. Director
. Division of Water Quality
On April 11, 2003, a representative of your animal operation informed the Division of
Water Quality (DWQ) that there was inadequate freeboard in the lagoon(s) serving this facility.
This lack of adequate freeboard is in non-compliance with the Certificate of Coverage
issued to this facility on March 13, 2001. In addition to this Notice of Violation (NOV), this
non-compliance is subject to an appropriate enforcement action by DWQ. This action can
consist of one or more of the following: a civil or criminal enforcement action; an injunction;
and/or a requirement to apply for coverage under an individual permit. The action chosen will
be based on complete evaluation of all factors that resulted in the inadequate freeboard; the
actions taken to restore the needed freeboard; and the actions being proposed to prevent the
problem from reoccurring.
To assist us in our review, please provide the Wilmington Regional Office with an
evaluation of the reasons for the freeboard violation(s) and a strategy to prevent future freeboard
violation(s). This evaluation and strategy must include but is not limited to the following:
Current Freeboard level(s)
Freeboard level records in the lagoon(s) for the past 12 months up to the date of submittal
Spraying records for the past 12 months up to the date of submittal
AM ENR
Customer Service: Mailing Address: Telephone [phone] Location:
1-877-623-6748 1617 Mail Service Center Fax [phone] N. Salisbury St.
Raleigh, North Carolina 276MI617 . State Courier #52-01-01 Raleigh, NC 27699-1617
An Equal Opportunity/Altirmative Action Employer
50 % recycled / 10% post -consumer paper
ht1pY1h2o.enr state.nc. us

Inadequate Freeboard
Page 2
Rainfall records for the past 12 months for this site up to the date of submittal (if
available)
Cropping system and PAN specified in the CAWMP. If the cropping system was not in
compliance with the facility's CAWMP, provide details of the cropping system in place
for the past 12 months.
A summary of actions taken to restore the needed freeboard in the Iagoon(s) including but
not limited to removal of animals from the site, delay of restocking of animals, pumping
and hauling waste to another site (specify site), securing additional irrigation equipment,
and securing additional spray sites.
A description of water conservation measures in use at the facility and the date(s)
installed.
If the lagoon level(s) are still in violation of the facility's CAWMP and Permit, provide
an updated Plan of Action as to how the facility will return to compliance.
Provide a detailed description of the actions taken or proposed to be taken to insure that
there are no further freeboard violations at this facility.
This information must be received by the Wilmington Regional Office at the following
address no later than 10 days following receipt of this letter.
Division of Water Quality
127 Cardinal Drive Extension
Wilmington, NC 28405-2845
Once this information is received and evaluated by the DWQ staff, a determination will
be made as to the appropriate compliance/enforcement actions to be taken. Each case will be
evaluated on its own merit. The efforts by the owner/producer to notify DWQ of the problem,
efforts made to resolve the problem once identified, and efforts proposed to prevent future
problems will be positive factors in this determination.
Nothing in this letter should be taken as removing from you either the responsibility or
liability for this non-compliance or future cases of non-compliance. If you have any questions
regarding this letter, please do not hesitate to contact our Wilmington Regional Office Staff at
[phone].
Sincerely,
Alan W. Klimek,
Director
cc: Wilmington Regional Office
Non -Discharge Compliance/Enforcement Unit
Central Files

04/30i2003 20:58 FAX [phone]
JUNIPER CREEK FA
01
May 1, 2003
TO: Rick Shriver
FROM: Marvin L. Evans
Re: Notice of NOV and deadline extension
H t / G-CV YS .
`T Cl' r`f Tb CrCT -r-rtI--
(7X--�-C..O S TO v 5 ,
April 11, 2003 after 3 days of rain my lagoon marker was into the red about one inch,
leaving approximately 18 inches showing on the marker_ As required by DWQ, I called
the Wilmington regional office and report this and also noted that some of the excess
could be pumped back into the houses. Since we had two houses that needed more Waft
in the pit. We had just been through the shipping and receiving process and had very
small pigs (nursery) that within would mean less waste going into the lagoon at this time.
Tuesday, April 22, 2003, I received a certified letter from DWQ. A NOV. The letter
stated that I bad ten days from the date of receiving to comply with requests make in the
letter_
The letter requested records dating back one year. I think this is excessive, since those
records were inspected by state representatives in November, 2002. This a lot of paper to
be copied and readied for delivery_
This request places an over -burden, considering the fact that we are very busy trying to
get our hay off our irrigation spray field, lower our lagoon level, get ready for conttnctual
no -trill re -sprigging next week, and add the fact that tomorrow we will be going through
our regular state inspection.
We need more time.
I called yesterday when we received another letter from DWQ about this matter. I have
tried several times to speak with you today. I will keep trying, however in the maim time
I am faxing this memo to you. If possible, I need an answer today_ Tomorrow is my
deadline date.
I can be reached at [phone].

f
ti 14
I-e-V
t4f • —'the=c14P 61tVe-
Frc ba r j-e S �1
� f crr6 - n�- G �i �
t �
-dq f_4 c./
rA nlx-M �qo 3
SJ! I

JINIPER CREEK FA
fij 02
04/30/2003 20:58 FAX [phone]
0
Nkhael F. EaMey
Gmemor
WM am G. Hans Jrw Searem y
Department of Environment wid Natual Ramumn
`C Wen W. Klimek. P.E. Director
.+ DivL<w of Water Ckm ty
April 16, 2003
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Marvin Evans
6889 Parker Road, NW
Ash NC 29420
SUBJECT: Notice of Violation
Request for Information
Inadequate Freeboard
Juniper Creek
# 10-29
Brunswick County
Dear Sir or Madam:
On April 11, 2003, a representative of your animal operation informed the Division of
Water Quality (DWQ) that there was inadequate freeboard in the lagoon(s) serving this facility.
This lack of adequate freeboard is in non-compliance with the Certificate of Coverage
issued to this facility on March 13, 2001. In addition to this Notice of Violation (NOV), this
non-compliance is subject to an appropriate enforcement action by DWQ. This action can
consist of one or more of the following: a civil or criminal enforcement action; an injunction;
and/or a requirement to apply for coverage under an individual permit. The action chosen will
be based on complete evaluation of all factors that resulted in the inadequate freeboard; the
actions taken to restore the needed freeboard; and the actions being proposed to prevent the
problem from reoccurring.
To assist us in our review, please provide the Wilmington Regional Office with an
evaluation of the Mons for the freeboard violation(s) and a strategy to prevent future freeboard
violation(s). This evaluation and strategy must include but is not Limited to the following:
Current Freeboard level(s)
Freeboard level records in the lagoon(s) for the past 12 months up to the date of submittal -
Spraying records for the past 12 months up to the date of submittal
NMM
CURICO er Ss ft. Mailing address: Telephone (019) 7 Lowden:
1 -077-623-i749 1617 Mail Service Center Fax [phone] N. SaNWblsy Sz
Raleigh, North Carolina 27699-1617 State Courier #52-01-01 Ralelgn, NC 2761i I07
An Equa! OppanuMryr 1 Affirmative action Ca prayer
50% recycredl 70% post-o►isurner paper
hrpY1h24D. enr. srare. rc- as

003
04/30/2003 20:58 FAX [phone] JUNIPER CREEK FA
Inadequate Freeboard
Page 2
Rainfall records for the past 12 months for this site up to the date of submittal (if
available)
Cropping system and PAN specified in the CAWNU. If the cropping system was not in
compliance with the facility's CAWW, provide details of the cropping system in place
for the past 12 months.
A summary of actions taken to restore the needed freeboard in the lagoon(s) including but
not limited to removal of animals from the site, delay of restocking of animals, pumping
and hauling waste to another site (specify site), securing additional irrigation equipment,
and securing additional spray sites.
A description of water conservation measures in use at the facility and the date(s)
installed.
If the lagoon level(s) are still in violation of the facility's CAWW and Permit, provide
an updated Plan of Action as to how the facility will return to compliance.
Provide a detailed description of the actions taken or proposed to be taken to insure that
there are no further freeboard violations at this facility.
This information must be received by the Wilmington Regional Office at the following
address no later than 10 days following receipt of this letter.
Division of Water Quality
127 Cardinal Drive Extension
Wilmington, NC 28405-2945
Once this information is received and evaluated by the DWQ staff, a determination will
be made as to the appropriate compliance/enforcement actions to be taken. Each case will be
evaluated on its own merit. The efforts by the owner/producer to notify DWQ of the problem,
efforts made to resolve the problem once identified, and efforts proposed to prevent future
problems will be positive factors in this determination.
Nothing in this fetter should betaken as removing from you either the responsibility er.-
liability for this non-compliance or future cases of non-compliance. If you have any questions
regarding this letter, please do not hesitate to contact our Wilmington Regional Office Staff at
[phone].
Sincerely,
r
Alan W. Klimek, .
Director
cc: Wilmington Regional Office
Non -Discharge Compliance/Enforcement Unit
Central Files

04/30/2003 20:58 FAX [phone]
t
JUNIPER CREEK FA 0041
William 13_ ROMIS Jr.. Smatary
Deparrmnt of Ermron.w and Nawral Rwour es
Alan W. If% ob. P.E. W aster
■�
`— Division ar wow �I>41
April 25, 2003
Dear Producer.
It has come to my attention that correspondence you recently received from the Division of Water Quality
(DWQ) regarding a Notice of Violation (NOV) and the associated request for information has caused
some concern among producers. The purpose of this letter is to give you additional information about the
reasons behind the letters and how this information will be used.
In accordance with current DWQ policy, we issued NOV's to all facilities that had non -compliant
freeboard levels. This is true for both producers who report these violations to DWQ as well as those
violations that were identified or verified by DWQ staff. I understand that unfortunately some producers
may be feeling that they made a mistake by reporting noncompliant freeboard because, after ter
repotted, they received a NOV. We believe that reporting was the correct and appropriate dag to da By
so doing, you have protected yourself from a Civil penalty for violating the self -reporting requirement that
applies to non -compliant freeboard_ We have taken or will be taking appropriate enforcement acting
against any producer who failed to make the required report By reporting, you avoided an enforcetneW
action for failure to report.
We acknowledge and appreciate the efforts of the many conscientious producers who made every
reasonable effort to properly manage their facilities. We also acknowledge and appreciate those
producers who notified us of problems with freeboard levels and who have worked diligently with our
division to manage lagoon levels at their farms_ These efforts, along with the requested information, will
definitely be taken into consideration as DWQ considers any further actions.
We have requested additional information from producers to enable us to determine the site -specific
factors that resulted in freeboard non-compliance at each facility. We will look at each case on its merits
Where the facts and law support and call for an enforcement action such as a civil penalty, we have taken
that action or will be taking it. However, just because you received an NOV for non -compliant fma owd
levels does not mean that we will take an additional, more serious enforcement action sgainst your
facility.
We also recognize that reporting this information will take effort on the part of producers at a time when
various circumstances have already increased the demands on your time and attention. For that reason, is
the NOV's we initially added five days to the time within which this information is required by your
permits to be submitted. If you have circumstances Omt will make meeting the 10-day deadline
rrnre+sonably urdensome to you, please contact your, regional DWQ office and discuss your individual
situation with them. Based on the explanation provided, when appropriate we will rriske every is a to "
work with you to establish a short extension of time for the submittal of the requested information.
I
91
I hope this letter will help clarify any questions or concerns that you may have had.
Sincerely, }
4'
Alan W. Klimek mek, P.E. '
Director
comer Service: Matting Address- Tdgmhc a (919) 733-=3 Loratimu ri
1477-623.6748 1617 Mail Serrim Center Fax [phone] $12 N. Sarsury SL -
Raleigh. North Carolina 276WI617 Static Courier#52-01-01 Raleigh, NC 276W1617
An Equal OppWunlrylAf m"afive Acton Empbyw
50% recycled! 70% yoy-=*SurnerPffW
MtpYRr 2o. em s tate. = vs

I'
Iv, ko
0, jr
Nutrient Management Plan For Animal Waste Utilization
04-30-2001
This plan has been prepared for:
Juniper Creek i i i . ( ; . I ' ; #
Marvin Evans �7'7� r ,
6889 Parker Road " .3 .1r &I J
Ash, NC 28420 I •.�,1 __}.
[phone]
This plan has been developed by:
Jeffery Brown
DSWC-FRO
225 Green Street
Fayetteville, NC 28301
'(910) 486-I541 p
De 6pvGSig&fure
Type of Plan: Nitrogen Only with Manure Only
Owner/Manager/Producer Agreement
I (we) understand and agree to the specifications and the operation and maintenance
procedures established in this nutrient management plan which includes an animal waste
utilization plan for the farm named above. I have read and understand the Required
Specifications concerning animal waste management that are i,pcluded with this plan.
v '
O
Signature (owner) Date
Signature (manager or producer) Date
This plan meets the minimum standards and specifications of the U.S. Department of
Agriculture - Natural Resources Conservation Service or the standard of practices
adopted by the Soil and Water Conservation Commission.
Plan Approved By: %r q — — o t
Te ni al Specialist Signature Date
MAY 13 N09
BY: '
--------------------------------------------------------------------------------------
886988 Database Version 1.06 Date Printed: 04-30-2001 Cover Page 1
RECEIVED I DENR / DWQ
AQUIFFR-PP0TFf'.T10N SFCTION
APR 0 12009

Nutrients applied in accordance with this plan will be supplied from the
following source(s):
Commercial Fertilizer is not included in this plan.
S5
Swine Nursery Lagoon Liquid waste generated 678,432 gals/year by a
3,552 animal Swine Nursery Lagoon Liquid operation. This production
facility has waste storage capacities of approximately 180 days.
Estimated Pounds of Plant Available Nitrogen Generated per Year
Broadcast
1564
Incorporated
2685
Injected
2957
Irrigated
1699
Actual PAN Applied
Year 1
2063
Notes:
In source ID, S means standard source, U means user defined source.
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
886988 Database Version 1.06 Date Printed: 04-30-2001 Source Page 1

Narrative
WUP is based on zones. Irrigation records need to be kept by zone to snatch WUP.
----------------------------- ------------------------------------------=------------
886998 Database Version 3.0E Date Printed: 04-30-2001 Narrative Page 1

The Waste Utilization table shown below summarizes the waste utilization plan for this operation. This plan provides an estimate of the number of acres of.
cropland needed to use the nutrients being produced. The plan requires consideration of the realistic yields of the crops to be grown, their nutrient requirements,
and proper timing of applications to maximize nutrient uptake.
This table provides an estimate of the amount of nitrogen required by the crop being grown and an estimate of the nitrogen amount being supplied by manure or
other by-products, commercial fertilizer and residual from previous crops. An estimate of the quantity of solid and liquid waste that will be applied on each field
in order to supply the indicated quantity of nitrogen from each source is also included.
A balance of the total manure produced and the total manure applied is included in the table to ensure that the plan adequately provides for the utilization of the
manure generated by the operation. Animal operations that generate liquid waste and utilize waste storage facilities (lagoons or holding ponds) may apply more or
less waste in any given year than is annually generated by the facility. In order to determine whether the plan adequately utilizes the waste produced by the
facility, the storage capacity table included in this plan should be reviewed to ensure that the design capacity of the storage facility is not exceeded during the
planning period.
Depending on the requirements of the crop and the nutrient content of the waste, some nutrients will likely be over or under applied if animal waste is being
utilized. Waste should be analyzed before each application cycle and annual soil tests are required if animal waste is being applied. Soil tests should be used to
balance the nutrient application amounts with the realistic yields of the crop to be grown. Nutrient management plans may require that the application of animal
waste be limited so as to prevent over application of phosphorous when excessive levels of this nutrient are detected in a field.
Waste Utilization Table Year 1
Tract
I Field
Source
I.D.
Soil Series
Total
Acre
Use.
Acres
Crop
RYE
RYE
Unit
Applic.
Period
Nitrogen
PA
Nutrient
Req'd
Comm.
Fert.
Nutrient
Applied
Res.
(lbs/A)
N
Applic.
Method
Manure
PA
Nutrient
Applied
Liquid
Manure
Applied
(acre)
Solid
Manure
Applied
(acre)
Liquid
Manure
Applied
(Field)
Solid
Manure
Applied
(Field)
N
N I
lbs/A
1000
gaUA
tons
1000 gals
tons
493
& 2 - 6
S5
Foreston
1.5
L5
Small Grain Overseed
1.0
Tons
1011-3/31
50
0
0
Irri .
50
20.0
0.0
29.3
0.0
493
& 2 - 6
S5
Foreston
1.5
1.5
Bermudagrass Pasture
6.0
Tons
311-9/30
* 180
0
0
Irri .
180
71.9
0.0
105.6
0.0
t 493
1-1
S5
Foreston
1.6
1.6
Small Grain Overseed
1.0
Tons
1011-3/31
50
0
0
Irri .
50
10.0
0.0
16.2
0.0
493
1-1
S5
Foreston
1.6
1.6
Bermuda ass Pasture
*6.0
Tons
311-9/30
* 180
0
0
Trri .
180
71.9
0.01
116.4
0.0
493
1-2
S5
Foreston
1.5
1.5
Small Grain Overseed
1.0
Tons
1011-3/31
50
0
0
Irri .
50
20.0
0-01
29.3
0.0
493
1-2
S5
Foreston
1.5
1.5
Bermudagrass Pasture
6.0
Tons
3/1-9/30
180
0
0
Irri .
180
71.9
0.0
105.6
0.0
493
1-3
S5
Foreston
L5
1.5
Small Grain Overseed
1.0
Tons
1011-3131
50
0
0
Irri .
50
21 0
0.0
29.3
0.0
493
1-3
S5
Foreston
1.5
1.5
Bermuda ass Pasture
6.0
Tons
3/1-9/30
* 190
0
0
Irri.
180
71.9
0.0
105.6
70
493
1-4
S5
Foreston
1.5
1.5
1 Small Grain Overseed
1.0
Tons
10/1-3/31
50
0
0
Irri .
50
20.0
0.0
29.3
0.0
-----------------------------------------------------------------------------------------------------------------------------------------
986988 Database Version 1.06 Date Printed: 04-30-2001 WUT Page i

Waste Utilization Table
Year 1
Tract
I Field
Source
I LD.
I Soil Series
Total
Acre
Use.
Acres
Crop
RYE
RYE
Unit
Applic.
Period
Nitrogen
PA
Nutrient
Req'd
Comm.
Fert.
Nutrient
Applied
Res.
(lbs/A)
N
Applic.
Method
Manure
PA
Nutrient
Applied
Liquid
Manure
Applied
(acre)
Solid
Manure
Applied
(acre)
Liquid
Manure
Applied
(Field)
Solid
Manure
Applied
(Field)
N
N
lbs/A
1000
I jzal/A
I tons A
1000pals
tons
493
1-41
SS
I Fores ton
1,51
1.5
1 Bermuda ass Pasture
1 6.0
1 Tons
311-9130
1 r 1801
0
0
I Irri
1801
71.91
0.0
1 105.6
0.0
493
1-51
S5
I Fores ton
1 1.51
1.5
1 Small Crain Oversced
1 1.0
1 Tons
I i011-3/31
1 501
0
0
irrig. 1
501
20.01
0.0
29.3
0.0
493
1-51
SS I
Foreston
1.51
1.5
1 Bermuda ass Pasture 1
6.0 1
Tons
311-9130
1 " 1801
01
0 1
Irfig. 1
180
71-9
0.0
105.6
0.0
Lagoon Liquids
Total Applied, 1000 gallons
807
Total Produced, 1000 gallons
678
Balance 1000 gallons
-129
Manure Solids
Total Applied, tons
0
Total Produced, tons
0
Balance tons
0
Notes: 1. In the tract column, symbol , means leased, otherwise, owned. 2. Symbol * means user entered data.
--------------------------------------------------------------------------------------------------------------- -----------------------
886988 Database Version 1.06 Date Printed: 04-30-2001 WUT Page 2

The Irrigation Application Factors for each field in this plan are shown in the following table.
Infiltration rate varies with soils. If applying waste nutrients through an irrigation system, you must
apply at a rate that will not result in runoff. This table provides the maximum application rate per hour
that may be applied to each field selected to receive wastewater. It also lists the maximum application
amount that each field may receive in any one application event.
Irrigation Ap lication Factors
Tract
Field
Soil Series
Application Rate
inches/hour
Application Amount
inches
493
1 & 2 - 6
Foreston
0.50
0.96
493
1-1
Foreston
0.50
0.96
493
1-2
Foreston
0.50
0.96
493
1 1-3
Foreston
1 .50
0.96
493
1-4
Foreston
0.501
0.96
493
.1-5
Foreston ..
0.501
0.96
--------------------------------------------------------------------------------------
886988 Database Version 1.06 Date Printed: 04-30-2001 IAF Page 1

The following Lagoon Sludge Nitrogen Utilization table provides an estimate of the number of acres needed for
sludge utilization for the indicated accumulation period. These estimates are based on average nitrogen
concentrations for each source, the number of animals in the facility and the plant available nitrogen application
hates shown in the second column.
goon sludge contains nutrients and organic matter remaining after treatment and application of the effluent. At
-an out, this -material must be utilized for crop production and applied at agronomic rates. In most cases, the
iority nutrient is nitrogen but other nutrients including phosphorous, copper and zinc can also be limiting. Since
trient levels are generally very high, application of sludge must be carefully applied.
(Sites must first be evaluated for their suitability for sludge application. Ideally, effluent spray fields should not be
used for sludge application. If this is not possible, care should be taken not to load effluent application fields with
high amounts of copper and zinc so that additional effluent cannot be applied. On sites vulnerable to surface water
I
oving to streams and lakes, phosphorous is a concern. Soils containing very high phosphorous levels may also be
a concern.
Lagoon Sludge Nitrogen Utilization Table
Crop
Maximum
PA-N Rate
lb/ac
Maximum Sludge
Application Rate
1000 allac
Minimum Acres
5 Years Accumulation
Minimum Acres
10 Years Accumulation
Minimum Acres
15 Years Accumulation.
Swine Nursery Lagoon Sludge - Standard
Corn 120 bu
1501
13.16
9.04
18.081
27.12
Hay. 6 ton R.Y.E.
300
26.32
4.52
91041
13.56
Soybean 40 bu
160
14.04
8.481
16.951
25.43
f
886988 Database Version 1.06 Date Printed: 04-30-2001 Sludge Page 1

The Available Waste Storage. Capacity table provides an estimate of the number of days of storage
capacity available at the end of each month of the plan. Available storage capacity is calculated as the
design storage capacity in days minus the number of days of net storage volume accumulated. The start
date is a value entered by the user and is defined as the date prior to applying nutrients to the first crop in
the plan at which storage volume in the lagoon or holding pond is equal to zero.
Available storage capacity should be greater than or equal to zero and less than or equal to the design
storage capacity of the facility. If the available storage capacity is greater than the design storage
capacity, this indicates that the plan calls for the application of nutrients that have not yet accumulated.
If available storage capacity is negative, the estimated volume of accumulated waste exceeds the design
storage volume of the structure. Either of these situations indicates that the planned application interval
in the waste utilization plan is inconsistent with the structure's temporary storage capacity.
Available. Waste Storage Capacity
Source Name
Swine Nursery Lagoon Liquid
Design Storage Capacity (Days)
Start Date
1 9/30
180
Plan Year
Month
Available Storage Capacity (Days)
1
1
115
1
2
Ill
1
3
112
1
4
117
1
5
155
1
6
180
l
7
180
1
8
180
1
9
180
1
10
161
1
11
151
1
12
128
* Available Storage Capacity is calculated as of the end of each month.
�.
886988 Database Version 1.06 Date Printed: 04-30-2001 Capacity Page 1

Required Specifications For Animal Waste Management
1. Animal waste shall not reach surface waters of the state by runoff, drift,
manmade conveyances, direct application, or direct discharge during
operation or land application. Any discharge of waste that reaches
surface water is prohibited.
2. There must be documentation in the design fold that the producer either
owns or has an agreement for use of adequate land on which to properly
apply the waste. If the producer does not own adequate land to properly
dispose of the waste, he/she shall provide evidence of an agreement with a
landowner, who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner
of the waste production facility to secure an update of the Nutrient
Management Plan when there is a change in the operation, increase in
the number of animals, method of application, receiving crop type, or
available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs
for realistic crop yields based upon soil type, available moisture,
historical data, climatic conditions, and level of management, unless
there are regulations that restrict the rate of applications for other
nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre
per year. Waste may be applied to land eroding at more than 5 tons per
acre per year but less than 10 tons per acre per year provided grass filter
strips are installed where runoff leaves the field (see USDA, NRCS Field
Office Technical Guide Standard 393 - Filter Strips).
5. Odors can be reduced by injecting the waste or by disking after waste
application. Waste should not be applied when there is danger of drift
from the land application field.
6. When animal waste is to be applied on acres subject to flooding, waste
will be soil incorporated on conventionally tilled cropland. When waste is
applied to conservation tilled crops or grassland, the waste may be
broadcast provided the application does not occur during a season prone
to flooding (see "Weather and Climate in North Carolina" for guidance).
--------------------------------------------------------------
886988 Database Version 1.06 Date Printed: 04-30-2001 Specification Page 1

7. Liquid waste shall be applied at rates not to exceed the soil infiltration
rate such that runoff does not occur offsite or to surface waters and in a
method which does not cause drift from the site during application. No
ponding should occur in order to control odor and flies.
8. Animal waste shall not be applied to saturated soils, during rainfall
events, or when the soil surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a
manner that the crop is not covered with waste to a depth that would
inhibit growth. The potential for salt damage from animal waste should
also be considered.
10. Nutrients from waste shall not be applied in fall or winter for spring
planted crops on soils with a high potential for leaching. Waste/nutrient
loading rates on these soils should be held to a minimum and a suitable
winter cover crop planted to take up released nutrients. Waste shall not
be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply
with the following: The outer perimeter of the land area onto which
waste is applied from a lagoon that is a component of a swine farm shall
be at least 50 feet from any residential property boundary and canal.
Animal waste, other than swine waste from facilities sited on or after
October 1, 1995, shall not be applied closer that 25 feet to perennial
waters.
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other
than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and
public right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways,
or wetlands by a discharge or by over -spraying. Animal waste may be
applied to prior converted cropland provided the .fields have been
approved as a land application site by a "technical specialist". Animal
waste shall not be applied on grassed waterways that discharge directly
---------------------------------------------------------------------------------------
886988 Database Version 1.06 Date Printed: 04-30-2001 Specification Page 2

into water courses, and on other grassed waterways, waste shall be
applied ar agronomic rates in a manner that causes not runoff or drift
from site.
16. Domestic and industrial waste from washdown facilities, showers, toilets,
sinks, etc., shall not be discharged into the animal waste management
system.
17. A protective cover of appropriate vegetation will be established on all
disturbed areas (lagoon embankments, berms, pipe runs, etc.). Areas
shall be fenced, as necessary, to protect the vegetation. Vegetation such
as trees, shrubs, and other woody species, etc., are limited to areas where
considered appropriate. Lagoon areas should be kept mowed and
accessible. Berms and structures should be inspected regularly for
evidence of erosion, leakage, or discharge.
18. If animal production at the facility is to be suspended or terminated, the
owner is responsible for obtaining and implementing a "closure plan"
which will eliminate the possibility of an illegal discharge, pollution, and
erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected
on a regular basis to prevent breakdowns, leaks, and spills. A regular
maintenance checklist should be kept on site.
20.. Animal waste can be used in a rotation that includes vegetables and other
crops for direct human consumption. However, if animal waste is used
on crops for direct human consumption, it should only be applied
pre -plant with no further applications of animal waste during the crop
season.
21. Highly visible markers shall be installed to mark the top and bottom
elevations of the temporary storage (pumping volume) of all waste
treatment lagoons. Pumping shall be managed to maintain the liquid
level between the markers. A marker will be required to mark the
maximum storage volume for waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested
at least annually at crop sites where waste products are applied.
886988 Database Version 1.06 Date Printed: 04-30-2001 Specification Page 3

r___N,
Nitrogen shall be the rate -determining nutrient, unless other restrictions
require waste to be applied based on other nutrients, resulting in a lower
application rate than a nitrogen based rate. Zinc and copper levels in the
soils shall be monitored and alternative crop sites shall be used when
these metals approach excessive levels. pH shall be adjusted and
maintained for optimum crop production. Soil and waste analysis
records shall be kept for a minimum of five years. Poultry dry waste
application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a
minimum of five years.
23. Dead animals will be disposed of in a manner that meets North Carolina
regulations.
----------------------------------------------.----------------------------------------
886988 Database Version 1.06 Date Printed: 04-30-2001 Specification Page 4

t'
Crop Notes
The following crop note applies to field(s): 1 & 2 - 6, 1-1, 1-2, 1-3, 14, 1-5
Small Grain: CP, Mineral Soil, low -leachable
In the Coastal Plain, oats and barley should be planted from October 15-October 30; and rye from
October 15-November 20. For barley, plant 22 seed/drill row foot and increase the seeding rate by 5% for
each week seeding is delayed beyond the optimum time. See the seeding rates table for applicable
seeding rate modifications in the current NCSU "Small Grain Production Guide". Also, increase the
initial seeding rate by at least 10% when planting no -till. Oats should be planted at 2 bushels/acre and
rye at 1-1 1/2 bushels/acre. Plant all these small grains at 1-1 1/2" deep. Adequate depth control is
essential. Review the NCSU Official Variety "green book" and information from private companies to
select a high yielding variety with the characteristics needed for your area and conditions. Apply no more
than 30 lbs/acre N at planting. Phosphorus and potash recommended by a soil test can also be applied at.
this time. The remaining N should be applied during the months of February -March.
The following crop note applies to field(s): 1 & 2 - 6, 1-1, 1-2, 1-3, 1-4, 1-5
Bermudagrass CP, Mineral Soil, Poorly Drained to Somewhat Poorly Drained.
Adaptation: Effective artificial drainage MUST be in place to achieve Realistic Yield Expectations
provided for these soils.
In the Coastal Plain, hybrid bermudagrass sprigs can be planted Mar. 1 to Mar. 31. Cover sprigs I" to 3"
deep (1.5" optimal). Sprigs should be planted quickly after digging and not allowed to dry in sun and
wind. For Coastal and Tifton 78 plant at least 10 bu/ac in 3' rows, spaced 2' to 3' in the row. Generally a
fate of 30 bu/ac is satisfactory to produce full groundcover in one or two years under good growing
conditions. Tifton 44 spreads slowly, so use at least 40 bu/ac in 1.5' to 2' rows spaced 1' to 1.5' in row.
For broadcast/disked-in sprigs use about 60 bu/ac. Soil test for the amounts of lime, phosphorus,
potassium and micronutrients to apply preplant and for annual maintenance. Apply 60 to 100 lb/ac N in
the establishment year in split applications in April and July. For established stands apply 180 to 240
lb/ac N annually in split applications, usually in April and following the first and second hay cuts.
Reduce N rates by 25% for grazing. Refer to NCSU Technical Bulletin 305 Production and Utilization
of Pastures and Forages in North Carolina for more information or consult your regional agronomist or
extension agent for assistance.
-------------
886988 Database Version 1.0( Date Printed: 04-30-2001 Crop Note Page 1

ammmucamLimm
L Ir k S' PVC PIPS SHALL BE HUSUM A WDUHUM OF Z4 DI® EN OE
GROUND BCHfICI $ SHALL ES HUAflm A M@IDR]Y OP SO WMES
P ALL PIPE SHALL BE CIAO W GAGXX= M PVC. WIN SUPPLY LINE
SIiAIL HE 4-MM BI DLL AND TM LATIMS SHAM. ME It & i 4 BRM BL
0. &Mmdm"gim rm sum as CL" wo.
4. SUCMLON PIPE ON PUMP SHALL BE NOMI ED AT A M-M OF 10 D
BOOW WATER SURFACE THROUGH un Or A ROATAmm LET=
0. SPIUREM SPACING SPB➢ OF
� O � zYl ►VAUAR E�ACBBAM 110.
S. UUMAMON PUNT SHALT. BE BGSUAT MODEL S 1 1/ETPV 10 EP BLS PHASE
DOW= DRA L BE THODGID TD R14.
7. UOUG►7ON PUMP SRUL BE IOCATID ON 70P OF CM WALL DWATON
YIPS Cox= FROM PUMP EMAll, FAM7 0 NO117m IT BM WAIL PIPS
SHALL BE ELM TO A HTDRANY AT THE MGn BASE WHMCN SHALL
BE COMU E= To Tm SUPPLY LDLFA
0. A TOTAL OF 0 SPNIIIS An EEQUIRM SENNOMER IOMU. 700M 1-1-M[
1/4' NOZZLE OPEBATDIB • SO Fn Li GPM OE EQUIP.
& A 1' fEB84LEUATIC QU10E COt1P1n nm 1iID>ffiN Comm (OE EpU1T.) REBATE
HE USED SO AT AIL S MNXLA1 CONIIECIOMH. A RUB= COVER 1SmAllL BE
USIID TO FwmT TDS QULCE COUPIB
10. =Wr =0 CONNWMN TYPE OHM, RE LEFT UP.To THE INSTALLER
DAM ON TEE NEEDS OF THE OROWES. 121O01Om@ Oman E OH S EMT
commwmxs r0E LJTBEAL PSO'IEI.MK
L 7== MEAGRE WDL BE PROVIDED AT ALL SLIA RNM TIES AND VALTM
IY PEf@BUES GAUGE AY ?HZ PUMP SHAH DO OLTCWX F=lb 70 IOSiUDE THAT
WASIEWAMM DOES NOT DAMAGE IL
I0. SUCMIQN PIPE ON THE PUMP SHALL BE 5-MR IN IHA=M SOME END OF
BTRAOIER SHALL SS nOTAUAD ON TIM END OF TM SUCMN MR A FOOT
VALVE CAN BE AN OPMR&L nWL
14. SUEZ mID OF PMUM DEVICE BHAIL DE MSTALM ON THE SUCMON SIDE
Of THE PUMP. TTPE AND IBAND SNAIL BE LER UP TO THE CONMAM= I.
IS AID 1,,WAOUON vnmr VALVm SHABR DBMAuxn AT TO MSOH AM
LOT PO OF THE H. STSTLI AND A7 THE ENDS OF TMR RUPPLT WUL
Mir
Am ! saar IRVT POE P
s a fur NAtl6Ioa MINION.
low 4NII
Js I
0-MM BTmm PIPE HIREVI:
OR S-LE PVC PIP! PAm;m%
M Yf . *wcz
-•-•- - -
HELD BOUNDARY
— — — —
DITCH BUFFER
4-INCH MAIN PVC SUPPLY LINE
S-INCH PVC LATERAL LINE
2-INCH PVC LATERAL LINE
x
Sppnnc .ER
Mi
GATE OR GLOBE VALVE
®
ZONE IDENTIFICATION NO.
A
TRAVERSE SURVEY POINT
9
TEMPORARY BENCHMARK
STATE OF NORTH CAROL
JUNIPER CREEK
'a"
a°IIE IH"err
nRAQ11WM OF OIrdLOmlM. BfAM.flL AM rATtlBaL �DOFI.'�
a
as
am a.96.0
n"IME OF AGE. AIm TAm OONNmgMtl1l
IRRIGATION DESIGN
.
.
Em
.�,-BEVNHWMCi
CDUMTIYi
ar
Masue >_e�

AM -I-
OR ffill-zab- W".
W01. -Mm*. � own 110140
WN
TZ:--

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
Michael F. Easley, Governor
William G. Ross, Jr., Secretary
MARVIN EVANS
JUNIPER CREEK
6889 PARKER ROAD, NW
ASH NC 28420
Dear Mr. Evans:
j MAR 2 s 2001
NCDENR
.._J
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
March 13, 2001
Subject: Certificate of Coverage No. AWS100029
Juniper Creek
Swine Waste Collection, Treatment,
Storage and Application System
Brunswick County
In accordance with your application received on December 14, 2000, and additional information
response, received February 22, 2001; we are forwarding this Certificate of Coverage (COC) issued to
Marvin Evans, authorizing the operation of the subject animal waste collection, treatment, storage and
land application system in accordance with General Permit AWG100000. This approval shall consist of
the operation of this system including, but not limited to, the management of animal waste from the
Juniper Creek facility, located in Brunswick County, with an animal capacity of no greater than 3552
Wean to Feeder swine and the application to land as specified in the Certified Animal Waste
Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations
as specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
The facility's CAWMP meets all requirements in place at the time of certification. However, it
appears that the irrigation system on site may not adequately cover all acreage listed in the Waste
Utilization Plan. The owner should address this inconsistency as soon as possible.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617
An Equal Opportunity Affirmative Action Employer
Telephone [phone] FAX [phone]
50% recycled/ 10% post -consumer paper

a
Certificate of Coverage AWS 100029
Juniper Creek
Page 2
Please be advised that any violation of the terms and conditions specified in this COC, the General
Permit or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS
143-215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This
request shall be made within 30 days of notification by the Division.
This COC is not automatically transferable. A name/ownership change application must be
submitted to the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the
right to apply for an individual non -discharge permit by contacting the engineer listed below for
information on this process. Unless such a request is made within 30 days, this COC shall be final and
binding.
e
The subject farm is located in the Wilmington Regional Office. The Regional Office Water
Quality Staff may be reached at [phone]. If you need additional information concerning this
COC or the General Permit, please contact Theresa Nartea at [phone] ext. 375.
Si erely,
err T. Stevens
cc: (Certificate of Coverage only for all cc's)
Brunswick County Health Department
Wilmington-Regional-Offce,—Water Quality -Section— -�
Brunswick County Soil and Water Conservation District
Permit File
NDPU Files

ri
rI A
State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Marvin Evans
Juniper Creek
6656 Mrytle Head Road
Ash NC 28420
Farm Number: 10 - 29
Dear Marvin Evans:
09WA
•
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
October 23, 2000 RECEIVED
WATER QUALtiY
NwalowpPommm
You are hereby notified that Juniper Creek, in accordance with G.S. 143-215.10C, must apply for coverage under an
Animal Waste Operation General Permit. Upon receipt of this letter, your farm has sixty (60) days to submit the attached
application and all supporting documentation. In accordance with Chapter 626 of 1995 Session Laws (Regular Session
1996), Section 19(c)(2), any owner or operator who fails to submit an application by the date specified by the
Department SHALL NOT OPERATE the animal waste system after the specified date. Your application must be
returned within sixty (60) days of receipt of this letter. Failure to submit the application as required may also subject your
facility to a civil penalty and other enforcement actions for each day the facility is operated following the due date of the
application.
The attached application has been partially completed using information listed in your Animal Waste Management
Plan Certification Form. If any of the general or operation information listed is incorrect please make corrections as noted on
the application before returning the application package. The signed original application, one copy of the signed application,
two copies of a general location map, and two copies of the Certified Animal Waste Management Plan must be returned to
complete the application package. The completed package should be sent to the following address:
North Carolina Division of Water Quality
Water Quality Section
Non -Discharge Permitting Unit
1617Mail Service Center
Raleigh; NC 27699-1617
If you have any questions concerning this letter, please call Theresa Nartea at [phone] extension 375 or
Stoney Matthis with the Wilmington Regional Office at [phone].
Zcely,
for Kerr T. Stevens
cc: Permit File (w/o encl.)
Wilmington Regional Office (w/o enc).)
1617 Mail Service Center, Raleigh, NC 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

State of North Carolina
Department of Environment and Natural Resources
Division of Water Quality
Non -Discharge Permit Application Form
(THIS FORM MA Y BE PHOTOCOPIED FOR USE AS AN ORIGINAL)
General Permit - Existing Animal Waste Operations
The following questions have been completed utilizing information on file with the Division. Please
review the information for completeness and make any corrections that are. appropriate. If a
question has not been completed by the Division, please complete as best as- ssible. Do o leave
any question unanswered. RECEIVE
1. GENERAL INFORMATION:
DEC_ 1 4-'200U
LI Facility Name: Juniper Creek
1.2 Print Land Owner's name: Marvin Evans w%I , r►:..-,MVMPARRI fm
1.3 Mailing
City, State: Ash NC Zip: 28420
Telephone Number (include area code): 910-287-5090 Fax 716 - a 2 i " 3 Q VS -"`HO VAr—,
1.4 County where facility is located: Brunswick
1.5 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a copy
of a county road map with the location of the farm identified): SR 1335 and SR 1334 Gravel Rd. on S. side of 1335 private
farm gravel lane about 3/4 mile down lane on right side W.
1.6 Print Farm Manager's name (if different from Land Owner):
1.7 Lessee's I Integrator's name (if applicable; please circle which type is listed): Carroll's Foods Inc
L8 Date Facility Originally Began Operation: 1/l/1993
1.9 Date(s) of Facility Expansion(s) (if applicable):
2. OPERATION INFORMATION:
2.1 Facility No.: 10 (county number); 29 (facility number).
2.2 Operation Description: Swine operation
Wean to Feeder
3552- Certified Design Capacity
Is the above information correct? Xyes; = no. If no, correct below using the design capacity of the facility
The "No. of Animals" should be the maximum number for which the waste management structures were designed.
Type of Swine No. of Animals Type of Poultry No. of Animals Type of Cattle No. of Animals
0 Wean to Feeder 0 Layer 0 Dairy
0 Feeder to Finish 0 Non -Layer 0 Beef
0 Farrow to Wean (# sow) 0 Turkey
0 Farrow to Feeder (# sow)
0 Farrow to Finish (# sow)
Other Type of Livestock on the farm: No. of Animals:
FORM: AWO-G-E 7/7/99 Page 1 of 4 to - 29

i1
3.
2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): 30.00 ; Required Acreage (as listed in the AWMP): 6
2.4 Number f lagoons/ (circle which is applicable):
2.5 Are subsurface drains present within 100' of any of the application fields? YES or O (please circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES or O (please circle one)
2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, NRCS Standards, etc.) (Swine Only)
%_&J,..' --r�.� i.�:,�� Pt c—,k 1'L`p' YE or NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited? \ O k Q :4
What was the date that this facility's land application areas were sited? . NOIl-k1 Qa
REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
3.2 Two copies of a general Iocation map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit application
for animal waste operations.
The CAWMP mast include the following components. Some of these components may not
have been required at the time the facility was certified but should be added to the
CAWMP for permitting purposes:
3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
33.3 A map of every field used for land application.
3.3.4 The soil series present on every land application field.
3.35 The crops grown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application field.
3.3.8 The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.3.10 A site schematic.
3.3.11 Emergency Action Plan.
3.3.12 Insect Control Checklist with chosen best management practices noted.
3.3.13 Odor Control Checklist with chosen best management practices noted.
3.3.14 Mortality Control Checklist with the selected method noted.
3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility.
3.3.16 Operation and Maintenance Plan.
If your CAWMP includes any components not shown on this list, please include the
additional components with your submittal.
Applicants Initials
` V l� V
FORM: AWO-G-E 7/7/99 Page 2 of 4 10 - 29

Facility Number: 10 - 29
Facility Name: Juniper Creek
4. APPLICANT'S CERTIFICATION:
I(A Mail`y k h L - C V \r1 s (Land Owner's name listed in question 1.2), attest that
this application for 'Z )Y- . c_ CT c e.V, Fa,r M (Facility name listed in question 1.1)
has been reviewed by me and is ac-C&ate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be returned to me as incomplete. y�
Signature �� 4 A t_A*A�' _ Date / � - � - 6 V
5. MANAGER'S CERTIFICATION: (complete only if different from the Land Owner)
I, N I -) aL� '' Q �, tl1 l_ C \} C'y15 (Manager's name listed in question 1.6), attest that this
application for C!. Z C e. K i aY` m (Facility name listed in question 1.1)
has been reviewed by me and is ccurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will he returned as incomplete.
Signature � y fma A_/:�lDate /' -a (5 a
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
1617 MAIL SERVICE CENTER
RALEIGH, NORTH CAROLINA 27699-1617
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
R90EIVED
DEC.14,. uuu
WATER QUALITY SECTION
Non-0isoharge Permithg
FORM: AWO-G-E 7/7/99 Page 3 of 4 10 - 29

DIVISION OF WATER QUALITY REGIONAL OFFICES (X/'98)
M
Aahc�- Re€lo=-l'WQ SupaTisor
S FF ood5 n FI aw
Asheville, NC 25801
(s2S) 251-6209
AV=Y
?~f._=
Buncombe
M�
B=k--
MCDCrWCH
Caldwell
),E bcil
C2 -OL-
PD13C
Clay
Rutbwfard
C=hZM
SGMin
"r-zywood
l=sylVam p
Hcad=c a z=xy
ly=t-ViEltRCEiQ-.Zl WQSL'?G.'Y'-5w
W=havia Bu:iir—di-£. Szis 71"
zyz.-viliz, NC �=x -01.
is 10)
zz (910) 4&6-070 7
A=saa M
0zbelznd Rom=
Sz..,.-roan
riore scoA
TY.�so�Sa:^ itc€.:i WQ S�-i:x
5ES Warg2-- t-J%= S
F%1rso�S�� ?�C 27107 -
s.: ! C:�1.j ! 1-4C I
.AM --#any Rza:mh
Ad= Stems
Dzvkn Wztaa€:
Davie W U=
Fray h Yana
C722fard
wls bingtce R=gioral WQ S==-V 7i
943 Wtshixq,,Dn Squzz-- WUH
Washing x, NC 27989
(2Sz) 94b-64s i -
Fax (; 975-3716
Bcaufact 10=S -
$--da - I =Oir
Cbowza
Pamlico
Cxvra
Pwquataak
c t=U*
P�--qua=z=
Dare
pin
fray_-s
'I Y=U
Gr...�
rr,iusshingtoa
Moa=s-jlc rZ-gi=ri WQ Su=--e sac
919 Nor.► Main St
Moa:--s-vMr- NC 29115
(7704) 66:-1699
Fax [704) 663- ,
Lincoln
Cabzs a Mi =b=y
Cz:graba Rowan.
Ovc'v- d SMaly
Gas= Briar
%-^:L=I -
Rapp Rcgiorrl WQ Si�
WOO n,-nDr.
Ralcgb, NC Z7611
[phone]
Fax [phone]
r,hm?ham Nash
Durham Nw:!=otva
Fdg==bc (sage
Graavilt Van=
xaiifax wit=
Joh== W==
LCM Rr�ii sin
W'itmiagt�a Repa4. WQ 5s ;��:s.:a
127 CzrdiraI D,-:vz E;s—+rion
Fi'7 gwr- NC 29405-3845
(910) 3-95-3900
Fzz (910) 350-2M4
-
CKM--= aarlaw
Calu=bw sad
Dsmiia
ORM: AWO-G-E 51..8r98
Page 4 of 4

3
37.99 Ac
I �l
8 13,013 Ac
` vI: 7} � r aC' �
4 3.0!
IoAa-- 9AC,
6.57Ac 2323 A,.
19/3LS
x
. x 1
1 a
_ 1
173.6 A.
t : 221 AC. -;
••'J. dry L.� � '
ti 1„n
Appraisal Company, Lre.
Aral Mapping Company
IT Ac
l�9t
• 1
' MC5 AC, 1 2e .,
j17 c Tn1x 319
22.047R U
Ac. -
TR1a.eu 1V319 '
16
3a aAc y3!
' . eee9 `•4 �
I
7AC.rl 3a"pl s:ce..
R 1` 152� Ac Fu 2
f335f4 15 6-0
t+ �• n.c ,� K 31Ac
Y • uCl •W MVG'Lj N "Citi
.4 J y:.?T C.UFU _— 1
T + 7 •£ :14
'_7,46 Ac
6
N!r 1 z=Ci
• 1C-
ti I•i� � r f
25
l� zzs I
64.22 Ac
le e6 Fc '' � ud • � Y •w*
1 35
-IL 1
13
`I zixps r.� s f
v
L ,
R ,
�U 284 I'30A 31
f94ac� ',930,. 90Ac y_
M2Ac.
' N
T 3
90Acs —'
evARs
L r" FARM
p 8fi�f
21 2 '
I1.43AC. -
I 7Zk S _ lggl y •, �i
~ A. ••`[. 'a,rlr• 5;, w..rhL a n�rrn,,�r. .. rr _ w - .. .-(
-
���e•.a? w ••1:: CL�1 'N .r —, p_ .�
r'rlrt .
' 'r .ol�0�r. 1 il.A - ■ ..1
[�,4 .1 ro 1p a.l• •� •.

Today the county -seat is at Bolivia.
Rear River shore shows its flowering ton Pl.
Brunswick County's southern border is
beauty from March through November.
formed by the Atlantic Ocean. The. Cape
On the shores of the Cape Fear River
Fear River acts as the county's eastern and
lies historic Brunswick Town. This col -
part of the northern border, while the
onial port town was begun in 1726 as a
Waccamaw River, to the west, partially
business venture. It was at this port in
-creates the line between Columbus and
Brunswick 'counties. Along. the counties
oceanic shore lies Tubbs Inlet, Shallotte
Inlet, Lockwood Folly Inlet and Corncake
Inlet.
All
The beaches along the ocean* are
f C p U N
popular spots for almost any. kind of
recreation. Holden Beach offers eleven
miles of gently sIoping, wide beaches with
J
M.
,a
w
� y
CktP
n4 -
9 !� p
4
�- -' Rlv
< 0 ... odor., 9�.�.
adr//r
a

:b
:13-��. Sr. 7�.5�'�3 'S,•�c?t_y+�' ?�'� Cie ':� ��;�C'S ?CR �P CR �'iA2S�`87 �""* ""�'S
Plaasa w at-= t--a ec PIatad =D-- to t2%0
y�a add=ass o : La =ava=ya sida of I!0­ii
*name of fa= (Please pr nt)
Address
-Mvusns ?hone No e
ra= location: Latitude and Long-itsde:.0 GSrM / 30 Vie- (=egt_ed) Also,
please attach a copy of a cou=cy =cad asap vit'.x location identiFied.
':yrpe of operation (sviae, ' layer. da. --y, etc.) „1yec--- ,Lo
Design capacity (=xmbe- of an Mil s) ; ? - .5- :Z-
,:.ve-rase size of cpe_-aticn: (I2 month pcpu? aticn avg.) : -R
Ave ---age a=eage needed for land application of waste faces) a La AGr�S
aazzzza ash zzszszz:szza=zsr+sszas�zzsa:zzz:zz:zs_�=a�sas---=zsz:aaz==s:zsa=azsaaa
Cif SpaCiAL21.8t CA= r;LIjCiLLCa
"
As a technical . specialist " designated by the NCrtti1 CarOl; -+a SOiI - and Wa.te-
Conse_*sation Ccsamission pursuant to ISA NCAC 6F .0005, I ce-t;;y that the ne%r or
eked -n.i n.a7 urLste "=.z:agem&= syste= as i ataileL' f�x or the fa-z a=ued move
hasan an;1 haste =a agement plan that meeta the design, c=r_st_jct=On,
ape -ration and maintei%knce-it-x=ds-fig and specificatloas of the Division of
r-%.- a
Mnvi=oumental Manage=e^t and the USDA -Soil Conse-vat_on se=+rice and/or the Ncrt
�
Carolina Soil and Water Corse_-v-atiC= CC=M Ssion pursuant to -15A Ne.XC Z3:0217 and
00
's5A NCAC 6F .0001-.0005. The following elements and their cc=espcndiac -;,;;=—
cites - ver^iffed by me or other designated tee=ca? spec'aliats M
CM
a=e included in the plan as applicable: r1--s;ram-^+ sepa_-at_ons }iaor
�� Q
equ valeait for lagoons or waste storage ponds; -waste storage -capac? �4ato
g-jantity zMd a=t of •land for waste ut? lizat_on (or use,of t1u--d pa---=y) ; access
or Ownership %?r
"f _ poper waste, a�n plicat_oe: "P=M,=t;�s_.:e�Ie - for ti=d=q of
��
applicatior_s; applicatioM rates; _loading rates; -and :te• coat-oh l of the C-i_s; ch e
of pollutants f= sto"rs.rate; ruioff�ev_ests less _evhe=e thz*i=te 25-yew, 24-Sour
"_
-(Please =- _ `oLS. /2ry !� D
Spa Cr 'L't- ca].� a5�sai��+mot P;�t) L�
Affiliation: /z W GS _
Ac'c_-ess (Agency) -2 �- Ale, BYcne Nc 4'
Sigsatten/'�CZG`��79�� Date:
ssazszzazz=asaz::: z: �a�z:zs �aza:zzz:zz::azzzzz�sz==azasszz z:zazzaazza
G�a�i�a«ase r Aft .
I (we) unde=stand the operation and-^u--7_nte_=a_-ce prate=sn~es established i3 t.ae
approved--m4mal waste =amagement plan for t'he fa_-m naafi above and wi11 i=pleme^t
these p=ocedu-_es. I (we) ):sow that' a-y additional a lr- Jon to the exf.stiag
design capacity of the waste =t=eatment and storage system or coast-uction of new
facile itis will re;uire a new to be nor"_ ;tte_-; to the Division cf
cc "
Mmviron=e_ tal Meamageme t before the new axii=adls are stocked_ Y (we) also
LU W
understand that there tasst be no discha----ge of anl=al waste f=cm tb_is system to
�W
s:.
srface Ovate-•-s of the state either tb_--oug= a za.n _ade conveyance or t2Lrough
—L
rmoff £=cm a•-sj:oz=_ "event leas seve--e than t'se 2S-year. 24-hour store. The
a,proved plaa_w 3I be filed at the fa= a=d at the office of -the local Soil ar. d
09
water Cone_ -nation Dist=it t
�o;:s3.r
sa=. of Lead (Please Print)
signature: _ --_ Date:
-se -print)
Na=.& of 2fa-agar, if different f--.= owner (Plea t
signature- - Date-
"r -_A .��a �e=tea-land cvn rsliip=ram •; -es notification Or a nei4<ce---tI]E; cation
(' f " -the " apgraves= pia ='is ;� C: nged1:- to be suhmitted to the Division of
r,-*v=rormmentai 2*.anagemeht-withi.n=50 days Of a t'_tIe t__- far_
/�'✓���
DES USZ 0bMY-_AC*n''ri#
/D-4z9
� z
C?':r
w at
z

'oday the county seat is at Bolivia.
'Brunswick County's southern border is
'3ned by the Atlantic Ocean. The. Cape
r River acts as the county's eastern and
of the northern border, while the
iA I- - - - -- --._ n-- .• .. I
Rear River shore shows its flowering
beauty from March through Novernber-
On the shores of the Cape Fear River
lies historic Brunswick Town. This col-
onial port town was begun in I726 as a
ton PI

EMERGENCY CY ACTION PLAN
PHONENUMBERS
DWQ 3 `35" jfkG G
EMERGENCY-MAi FAGEVIE�FT SYSTEyI
S`VCD
NRCS
This plan will be implemented in the evem that wastes from your operation are leaking,
overrlowina. or running off site. You should not wait until wastes reach surface waters or
leave your property to consider that you have a problem. You should make :very effort to
ensure that this does not happen. This plan should be posted in an accessible location for
all employees at the facility. The following are some action items you should take.
1. Stop the release of wastes, Depending on the situation.'this may or may not be
possible. Suggested responses to some possible problems are listed below.
A. Laeoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c_ Stop all Bows to the Iagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B: Runoff from waste application field -actions include:
a Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reasons) that caused the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C: Leakaae from the waste pipes and sprinklers -action include:
a. Stop recycle pump.
b. Stop irrigation primp.
c. Close valves to eliminate further discharge.
d. Repair all Ieaks prior to restarting pumps.
D: Leakage from flush systems. houses, solid separators -action include:
a. Stop recycle pump.
b. Stop irrigation pump_
c. flake sure no siphon occurs.
d. Stop all flows in the 'louse. flush systems. or solid separators.
December ! S. 1996

e. Repair all leaks prior to restarting pumps.
E: Leakage from base orsidewall of lagoon. Often this is seepage -as opposed to
flowing leaks- possible action:
a. Dig a small sump or ditch awdy from the embankment to 'CaEch alI seepage,
put in a submersible pump. and pump back to lagoon.
b. If holes are caused by burrowing animals. trap or remove animals and fill
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon
bottom as soon as possible.
?. Assess the extent of the spill and note any obvious damages.
a_ Did the waste reach any surface waters'?
b. Approximately how much was released and for what duration?
c. Anv damage noted, such as employee injury, fish hills. or propery damage?
d. Did the spill leave the property? r
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
Are potable water wells in danger (either on or off of the property)?
h. How mach reached surface waters?
3: Contact appropriate agencies.
a. During normal business hours, call your DWQ (Division of Water Quality)
regional office; Phone - - After hours, emergency number: 919-t3-3942.
-Your phone call should include: your name, facility, telephone number, the details
of the incident from item 2 above, the exact location of the facility, the Iocation or
direction of movement of the spill. weather and wind conditions. The corrective
measures that have been under taken, and the seriousness of the situation.
b. If spill leaves property or enters surface waters, call local EMS Phone number -
c. Instruct EIMS to contact Local Health Department.
d. Contact CES, phone number - - , local SWCD office phone number
and local MRCS office for advice/technical assistance phone -number - -
1: If none of the above works call 911 or the Sheriffs Department and explain your
problem to them and ask that person to contact the proper agencies for you.
5: Contact the contractor of your choice to begin repair of problem to minimize off -site
damage.
a. Contractors Name:
b. Contractors Address:
c. Contractors Phone.
December 18. 1906

6: Contact the technical specialist who certified the lagoon (;VRCS. ConsultinL,
Eng*inter. etc.)
a. Name:
b. Phone:
7: Implement procedures as. advised by DWQ and technical assistance agencies to
rectift- the damage. repair the system. and reassess the waste management plan to
- beep problems with release of wastes from happening again.
December IS. 1990

s
Ar- t
INSECT CONTROL CHECKLIST FOR ANIMAL OPERATIONS
Source Cause BMP's to Minimize Odor Site Specific Practices
(Liquid Systems)
Flush Gutters Accumulation of solids M Hush system is designed and operated
sufficiently to remove accumulated
solids from gutters as designed.
(I Remove bridging of accumulated solids at
discharge
Lagoons and Pits Crusted Solids { Maintain lagoons, settling basins and
pits where pest breeding is apparent to
minimize the crusting of solids to a depth
of no more than 6-8 inches over more than
30% of surface.
Excessive Vegetative
Decaying vegetation
Growth
Feeders
Feed Spillage
Feed Storage
Accumulations of feed residues
Animal Holding Areas
Accumulations of animal wastes
and feed wastage
AMIC--November 1 1 , 1996
Maintain vegetative control along banks of
lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along water's edge on impoundment's perimeter.
(Dry Systems)
{ I Design, operate and maintain feed systems (e.g.,
bunkers and troughs) to minimize the accumulation
of decaying wastage.
(I Clean up spillage on a routine basis (e.g. 7-10 day
interval during summer; 15-30 day interval during winter).
{ j Reduce moisture accumulation within and around
immediate perimeter of feed storage areas by
insuring drainage away from site and/or providing
adequate containment (e.g., covered bin for
brewer's grain and similar high moisture grain
products).
I 1 Inspect for and remove or break up accumulated
solids in filter strips around feed storage as needed.
(I Eliminate low area that trap moisture along fences
and other locations where waste accumulates and
and disturbance by animals is minimal.
(1 Maintain fence rows and filter strips around animal
holding areas to minimize accumulations of wastes
(i.e. inspect for and remove or break up accumulated
solids as needed).

Dry Manure Handling Accumulations of animal wastes { j Remove spillage on a routine basis (e.g. 7-10 day
Systems interval during summer; 15-30 days interval during
winter) where manure is loaded for land application
or disposal.
(I Provide for adequate drainage around manure stockpiles.
{ 1 Inspect for and remove or break up accumulated wastes
in filter stripes around stockpiles and manure handling
areas as needed.
The issues checked ( ) pertain to this operation. The landownerCntegrator agrees to use sound judgment in applying
insect control measures as practical.
I certify the aforementioned insect control Best Management Practices have been reviewed with me.
Ila
(Landowner Signature)
For more information contact the Cooperative Extension Service, Department of Entomology, Box 7613, North Carolina State University, Raleigh, NC
27695-7613.
AMIC--November 11, 1996

ANIMAL WASTE UTILIZATION PLAN
-------------------------------------------------------------
Producer: MARVIN EVANS
Location: 6656 MYRTLE HEAD RD
ASH NC 28420
Telephone: [phone]
Type Operation: Existing Wean to Feeder Swine
Number of Animals: 3552.00 pigs
(Design Capacity)
STORAGE STRUCTURE: Anaerobic Waste Treatment Lagoon
APPLICATION METHOD: Irrigation
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops
in the fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply
more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall not be applied to land eroding at less
than 5 tons per acre per year. Waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on saturated soils, when it is raining,
or when the surface is frozen. Either of these conditions
may result in runoff" to surface waters which is not allowed
under DEM regulations.

9
----------------------------------------------------------------------
Page: 1
ANIMAL WASTE UTILIZATION PLAN
----------------------------------------------------------------------
5. Wind conditions should also be considered to avoid drift and
downwind odor problems.
6. To maximize the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more than 30
days prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. If
you choose to change methods in the future, you need to revise this
plan. Nutrient levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from your
waste management facility. In some cases you may want to have plant
analysis made, which could allow additional waste to be applied.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
This waste utilization plan, if carried out, meets the requirements
for compliance with 15A NCAC 2H .0217 adopted by the Environmental
Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
3552 pigs x .40 tons waste/pigs/year = 1420.8 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
3552 pigs x .48 lbs PAN/pigs/year = 1704.96 lbs. PAN/year
Applying the above amount of waste is a big job. You should plan time and
have appropriate equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on the
crop to be grown, soil type and surface application.

I
a3u2'
----------------------------
Page: 2
ANIMAL WASTE UTILIZATION PLAN
----------------------------------------------------------------------
TABLE 1: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
-------
APPLY
RESID.
APPLIC
METH
N
TIME
493
1
FO
BP
4.5
225
0
10.5
2362'.5
I
APR-SEP
493
4.5 225
12 IFO
II IBP 10
12 1450 SEP
492 3
FP 3 0
5
IWO
I 1150
1900
SEPT-APR
492 4
FP 3 0
4
IWO
II 1150
1600
SEPT-APR
END
I
TOTALI4312.5
- Indicates that this field is being overseeded (i.e. interplanted) or
winter annuals follow summer annuals.
NOTE: The applicator is cautioned that P and K may be over applied while
meeting the N requirements. In the future, regulations may require
farmers in some parts of North Carolina to have a nutrient management
plan that addresses all nutrients. This plan only addresses nitrogen.

----------------------------------------------------------------------
Page: 3
ANIMAL WASTE UTILIZATION PLAN
----------------------------------------------------------------------
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
see required specification 2.)
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
----
or
-------
APPLY
RESID.
APPLIC
METH
N
TIME
END
TOTAL 10
- Indicates that this field is being overseeded (i.e. interplanted) or w
annuals follow summer annuals.
** Acreage figures may exceed total acreage in fields due to overseeding.
* lbs AW N (animal waste nitrogen) equals total required nitrogen less
any commercial nitrogen (COMM N) supplied.

The following legend explains the crop codes used in tables 1 and 2 above:
CROP CODE
CROP
UNITS
PER UNIT
BP
FP
HYBRID BERMUDAGRASS-PASTURE
TALL FESCUE -PASTURE
TONS
50
50
TOTALS FROM TABLES 1 AND 2
ACRES LBS AW N USED
TABLE 1 22.5 4312.5
TABLE 2 0 0
---------------------------------------------------
KaiVA0
------------
Page: 4
ANIMAL WASTE UTILIZATION PLAN
------------------------------------------------------
22.5
*** BALANCE
4312.5
-2607.54
-------------------
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.

----------------------------------------------------------------------
Page: 5
ANIMAL WASTE UTILIZATION PLAN
-----------------------------------------------------------------------
*** This number must be less than or equal to 0 in order to fully utilize
the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the usable
acres excluding required buffers, filter strips along ditches, odd areas
unable to be irrigated, and perimeter areas not receiving full application
rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the
tables.
See attached map showing the fields to be used for the utilization of
animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient
rich and will require precautionary measures to prevent over application

of nutrients or other elements. Your production facility will produce
approximately 269.952 pounds of plant available nitrogen per year in the
sludge.
If you remove the sludge every 5 years, you will have approximately 1349.76
pounds of PAN to utilize. Assuming you apply this PAN to hybrid
bermudagrass hayland at the rate of 300 pounds of nitrogen per acre, you
will need 4.4992 acres of land. If you apply the sludge to corn at
the rate of 125 pounds of nitrogen per acre, you will need 10.79808 acres
of land. Please be aware that these are only estimates of the PAN and
land needed. Actual requirements could vary by 25% depending on your
sludge waste analysis, soil types, realistic yields, and application
methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the
soil at the time of irrigation such that runoff or ponding occurs. This
rate is limited by initial soil moisture content, soil structure, soil
texture, water droplet size, and organic solids. The application amount
should not exceed the available water holding capacity of the soil at the
time of irrigation nor should the plant available nitrogen applied exceed
the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan,
it is the responsibility'of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables 1 and 2. Failure to apply the recommended rates and
----------------------------------------------------------------------
Page: 6
ANIMAL WASTE UTILIZATION PLAN
--------------------------------------------------------------
amounts of nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for 'establishing application
rates and amounts.
Tract
Field
Soil Type
Crop
Application Rate
(in/hr)
Applic. Amount
(inches)
492
3
WO
FP
0.4
*1.3
492
4
WO
FP
0.4
*1.3
493
1
FO
BP
.5
*.95

493 2 FO
BP
0.5 1 *0.95
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations, the application amount shown cannot
be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180.00 days of temporary storage and the
temporary storage must be removed on the average of once every 6.00 months.
In no instance should the volume of the waste be stored in your stracture
be within the 25 year 24 hour storm storage or one foot of freeboard except
in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure
that the spreader equipment is operated properly to apply the correct rates
to the acres shown in Tables 1 and 2. Failure to apply the recommended
rates and amounts of nitrogen shown in the tables may make this plan
invalid.
Call your technical specialist after you receive the waste analysis report
for assistance in determining the amount of waste per acre and the proper
application rate prior to applying the waste.
NARRATIVE OF OPERATION
----------------------------------------------------------------------
Page: 7
WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does

not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
5. Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
5. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application.
does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be considered.
Page: 8
--------------------------------------------------------------------
WASTE UTILIZATION PLAN
--------------------------------------------------------------------
REQUIRED SPECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for

leaching. Waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to
wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly inton water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
the site.
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 9
--------------------------------------------------------------------
WASTE UTILIZATION PLAN

REQUIRED SPECIFICATIONS
18. If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22. Waste shall be tested within 60 days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element. zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when then
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be
maintained for five (S) years.
23. Dead animals will be disposed of in a manner that meets North
Carolina requlations.
Page: 10

ANIMAL WASTE UTILIZATION PLAN
--------------------------------------------------------------------
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm:JUNIPER CREEK
Owner/Manager Agreement
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
North Carolina Division of Environmental Management (NCDEM) before
the new animals are stocked. I (we) also understand that there
must be no discharge of animal waste from this system to surface
wasters of the state from a storm event less severe than the 25-
year, 24-hour storm. The approved plan will be filed on -site at
the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDEM
upon request.
Name of Facility Owner: MARVIN EVANS
(_Please print)
Signature: e ,y �� n Date: S` �(� 7z
Name of Manager(If different from owner):
Signature:
Date:
Name of Person Preparing Plan: (Please print)Harold D. Jones
Affiliation:NRCS Phone No. 910-253-2830
Address (Agency): P.O. Box 25
Bolivia NC 28422
Signature: Date:

i
rl
IA=y;{o
+�1g'tkl�3t'Y�,a[�IS'•w�wyyLL
lit, G
rr�P
4 1 li
r`+' r ..ppqqCC
��

y"
ry`'�-� 'ram :.✓ ii

MORTALITY MANAGEMENT METHODS
(check which method(s) are being implemented)
( ) Burial three feet beneath the surface of the ground within 24 hours
after knowledge of the death. The burial be at least 300 feet from
any flowing steam or public body of water.
�enderin-g at a rendering plant licensed under G. S. 106-168.7
{ j Complete. incineration
{ ) In the case of dead poultry only, placing in a disposal pit of a size and
design approved by the Department of Agriculture.
( } Any method which in the professional opinion of the State
Veterinarian would make possible the salvage of part of a dead
animal's value without endangering human or animal health. (Written
approval of the State Veterinarian must be attached)

SWINE FARM WASTE MANAGEMENT_ ODOR CONTROL CHECKLIST
Source Cause
BMP's to Minimize Odor Site Specific Practices
Farmstead Swine production
VVegetative or wooded buffers;
{Recommended best management
practices;
{Good judgment and common sense
Animal body surfaces Dirty manure -covered animals
WDry floors
Floor surfaces Wet manure -covered floors
(y 5lotted floors;
Waterers located over slotted floors;
( )/Feeders at high and of solid floors;
(+K scrape manure buildup from floors;
{) Underfloor ventilation for drying
Manure collection pits Urine (Orequent manure removal by fiush,pit
recharge,or scrape
Parital micorbial decomposition (} Underfloor ventilation
Ventilation exhaust fens Volatile gases; Fan maintenance;
Dust M/Ef icient air movement
Indoor surfaces Dust ( Washdown between groups of animals
{ } Feed additives;
{) Feeder covers;
[) Feed delivery downspout extenders to
feeder covers
Flush tanks Agitation of recycled lagoon
(1 Flush tank covers
liquid whiles tanks are filling
(1 Extend fill lines to near bottom of
tanks with anti -siphon vents
Flush alleys Agitation during wastewater
[) Underfloor flush with underfloor
conveyanance
ventdetion
Pit recharge points Agitation of recycled lagoon ( ) Extend rechard lines to near bottom of
liquid while pits are filling pits with anti -siphon vents
Lift stations Agitation during sump tank filling { } Sump tank covers
and drawdown
Outside drain collection Agitation during wastewater { } Box covers
or junction boxes conveyance
End of drainpipes at lagoon Agitation during wastewater () Extend discharge point of pipes
underneath lagoon liquid level
Lagoon surfaces Volatile gas emissions (Proper lagoon liquid capacity
Biological mixing Wcorrect lagoon startup procedures
Agitation ( ) Minimum surface area -to -volume ratio
(Minimum agitation when pumping
( ))Mechanical aeration
(%T Proven biological additives
Irrigation sprinkler nozzles High pressure agitation Irrigate on dry days with little or no wind
Wind draft (Minimum recommended operation pressure
{Pump intake near lagoon liquid surface
( ) Pump from second -stage lagoon
AMOC—November 11, 1996

Storage tank or basin
surface
Partial microbial decomposition
Mixing while filling
Agitation when emptying
( ) Bottom or midlevel loading
I 1 Tank covers
{ } Basin surface mats of solids
{ } Proven biological additives or oxidants
Settling basin surface Partial micobial decomposition I } Extend drainpipe outlets underneath liquid
Mixing while filling level
Agitation when emptying I 1 Remove settled solids regularly
Manure, slurry or sludge Agitation when spreading { } Soil injection of slurry/sludges
spreader outlets Volatile gas emissions { } Wash residual manure from spreader after use
{ } Proven biological additives or oxidants
Uncovered manure, slurry Volatile gas emissions while drying ( I Soil infection of slurry/sludges
or sludge on field surfaces f 1 Soil incorporation within 48 hours
{ } Spread in thin uniform layers for rapid drying
(1 Proven biological additives or oxidants
Dead animals Carcass decomposition Proper disposition of carcasses
Dead animal disposal Carcass decomposition (} Complete covering of carcasses in burial pits
pits (1 Proper location/construction of disposal pits
Incinerators Incomplete combustion [ } Secondary stack burners
Standing water around Improper drainage Grade and landscape such that water drains
facilities Microbial decomposition of away from facilities
organic matter
Manure tracked onto public Poorly maintained access roads (4 Farm access road maintenance
roads from farm access
Additional Information:
Available From:
Swine Manure Management; 0200 Rule/BMP Packet NCSU-County Extension Center
Swine Production Farm Potential Odor Sources and Remedies, EBAE Fact Sheet
NCSU-BAE
Swine Production Facility Manure Management: Pit Recharge —Lagoon Treatment; EBAE 128-88
NCSU-BAE
Swine Production Facility Manure Management: Underfloor Fluse—Lagoon Treatment; EBAE 129-88
NCSU-BAE
Lagoon Desig and Management for Livestock Manure Treatment and Storage; EBAE 103-83
NCSU-BAE
Calibration of Manure and Wastewater Application Equipment; EBAE Fact Sheet
NCSU-BAE
Controlling Odors from Swine Buildings; PIH-33
NCSU-Swine Extension
Environmental Assuranc Program: NPPC Manual
NC Pork Produces Assoc
Options for Managing Odor; a report from the Swine Odor Task Force NCSU Agri Communications
Nuisance Concerns in Animal Manure Management: Odors and Flies; PRO107, 1995 Conference Proceedings Florida Cooperative Extension
The issues checked ( ) pertain to this operation. The landownerfintegrator agrees to use sound judgment in applying
odor control measures as practical-.
I certify the aforementioned odor control Best Managment Practices have been reviewed with me.
(Landowner Signature)
AMOC--November 11. 1996

i o8/05/98 12:49 '09102962122 USDA MRCS
L
OFFRArflON & 1vMARMNANCE PLAN
Proper lagoon liquid management should be a -round priority. It is especia .y
important to manage levels so that you do not ave problems during extended rainy and
wet periods.
Maximum storage capacity should be available in the lagoon for periods when the
receiving crop is dormant (such as wintertime for bermudagrass) or when there are
extended rainy spells such as the thunderstorm season in the summertime This means
that at the first signs of plant growth in the later winter/early spring, irrigation according to
a farm waste management plan should be done whenever the land is dry enough to
receive lagoon liquid. This will make storage space available in the lagoon for future wet
periods. In the late summer/early fall the lagoon should be pumped down to the low
marker (see Figure 2-1) to allow for winter storage. Every effort should be made to
maintain the lagoon close to the minimum liquid level as long as the weather and waste
utilization plan will allow it.
Waiting until the Iagoon has reached its maximum storage capacity before starting to
irrigate does not leave room for storing excess water during extended wet periods.
Overflow from the lagoon foF any reason except a 25-year, 24-hour storm is a violation of
state law and subject to penalty action. `
The routine maintenance of a lagoon involves the following:
Maintenance of a vegetative cover for the dam.
Fescue or common bermudagrass are the most common vegetative
covers. The vegetation should be fertilised each year, if needed, to
maintain a vigorous stand. The amount of fertiliser applied should be
based on a soils test, but in the event that it is not practical to obtain
a soils test each year, the lagoon embankment and surrounding areas
should be fertilized with 800 pounds per acre of 10-10-10, or
equivalent.
Brush and trees on they embankment must be controlled. This may be
done by mowing, spraying, g az ng, chopping, or a combination of
these practices. This should be done at least once a year and
possibly twice in years, that weather conditions are favorable for
heavy vegetative growth_
NOTE: If vegetation is controlled by spraying, the herbicide must not be allowed to enter
the lagoon water. Such chemicals could harm the bacteria in the lagoon that are treating
the waste.
Maintenance -inspections of the entire lagoon should be made during the initial filling of
the lagoon and at least monthly and after major rainfall and storm events. Items to be
checked should include, as a minimum, the following:
Waste Inlett Pipes, Recycling Pipes, and Overflow Pipes —look for:
1. separation of joints
2. cracks or breaks
3. accumulation of salts or minerals
4. overall condition of pipes

0$/05/98 12:51 09102962122 USDA NRC5
fM 002
Lagoon surface ---look for:
1. undesirable vegetative growth
2, floating or lodged debris
Embankment ---look for:
1. settlement, cracking, or "jug" holes
2. side slope stability ---slumps or bulges
3. wet or damp areas on the back slope
4. erosion due to lack of vegetation or as a result of wave action
5. rodent damage
Larger lagoons may be subject to linter damage due to wave action caused by strong
winds. These waves can erode the lagoon sidewalls, thereby weakening the lagoon dam.
A good stand of vegetation will reduce the potential damage caused by wave action. If
wave action causes serious damage to a lagoon sidewali, baffles in the lagoon may be
used to reduce the wave impacts.
Any of these features could lead to erosion and weakening of the dam. If your lagoon has
any of these features, you should call an appropriate expert familiar with design and
construction of waste lagoons. You may need to provide a temporary fix if there is a threat
of a waste discharge. However, a permanent solution should be reviewed by the
technical expert. Any digging into a lagoon dam with heavy equipment is a serious
undertaking with potentially serious consequences and should not be conducted unless
recommended by an appropriate technical expert.
Transfer Pumps --check for proper operation of:
1. recycling pumps
2. irrigation pumps
Check for leaks, Ioose fittings, and overall pump operation. An unusually loud or grinding
noise, or a large arnount of vibration, may indicate that the pump is in need or repair or
replacement.
NOTE: Pumping systems should be inspected and operated frequently enough so that you
are not completely "surprised" by e4uipment failure. You should perform your pumping
system maintenance at a time when your lagoon is at its low level. This will allow some
safety time should major repairs be required. Halving a nearly full lagoon is not the fime
to think about switching, repairing , or borrowing pumps. Probably, if your lagoon is full,
your neighbor's lagoon is full also. You should consider maintaining an inventory of spy
parts or pumps.'
Surface water diversion features are designed to carry all surface
drainage waters (such as rainfall runoff, roof drainage, gutter outlets,
and parking lot runoff) away from your lagoon and other waste
treatment or storage structures. The only water that should be
coming from your lagoon is that which comes from your flushing
(washing) system pipes and the rainfall that hits the lagoon directly.
You should inspect your diversion system for the following:
I . adequate vegetation
2. diversion capacity
3. ridge berm height

08/05/98 12:52 129102962122 USDA MRCS 0 003
Identified problems should be corrected promptly. It is advisable to inspect your system
during or immediately following a heavy rain. If technical assistance is needed to
determine proper solutions, consult with appropriate ems.
You should record the level of the laoon just prior to when rain is predicted, and then
record the level again 4 to 6 hours after the rain (assumes there is no pumping). This will
give you an idea of how much your lagoon level will rise with a certain rainfall amount
(you must also be recording your rainfall for this to work). Knowing this should help in
planning irrigation applications and storage. If your lagoon rises excessively, you may
have an inflow problem from a surface water diversion or there may be seepage into the
lagoon from the surrounding land.
14goon Operation
Startup:
1. Immediately after construction establish a complete sod cover on bare soil
surfaces to avoid erosion.
2. Fill new IiVoon design treatment volume at least half full of water before
waste loading begins, taking care not to erode lining or bank slopes.
3. Drainpipes into the lagoon should have a flexible pipe extender on the
end of the pipe to discharge near the bottom of the lagoon during initial
filling or another means of slowing the incoming water to avoid erosion of
the lining-
4. When possible, begin loading new lagoons in the spring to maximize
bacterial establishment (due to warmer weather).
5. It is recommended that a new lagoon be seeded with sludge from a healthy
worldng swine lagoon in the amount of 0.25 percent of the fall lagoon
liquid volume. This seeding should occour at least two weeks prior to the
addition of wastewater.
6. Maintain a periodic check on the lagoon liquid pH. If the pH falls below,
7.01 add agricultural lime at the rate of 1 pound per 1000 cubic feet of
lagoon liquid volume until the pffrises above 7.0. Optimum lagoon liquid
pRis between 7.5 and 8.0.
7. A dark color, lack of bubbling, and excessive odor signals inadequate
biological activity. Consultation with a technical specialist is recommended
if these conditions occur for prolonged periods, especially during the warm
season.
Loading:
The more frequently and regularly that wastewater is added to a lagoon, the better the
lagoon will function. Flush systems that wash waste into the lagoon several times daily are
optimum for treatment. Pit recharge systems, in which one or more buildings are drained
and. recharged each day, also work well.

08/05/98 12:53 V9102962122 USDA MRCS Q 004
Practice water conservation ----minimize building water usage and
spillage from leaking waterers, brokers pipes and washdown through
proper maintenance and water conservation.
Minimize feed wastage and spillage by keeping feeders adjusted. This
will reduce the amount of solids entering the lagoon
Management:
Maintain lagoon liquid Ievel between the permanent storage level and
the full temporary storage level,
Place visible markers or stakes on the lagoon bank to show the
minimum liquid level and the maximum liquid lever (Figure 2-1).
Start irrigating at the earliest possible date in the spring -based on
nutrient requirements and soil moisture so that temporary storage
will be maximized for the summer thunderstorm season. Similarly,
irrigate in the late summerlearly fall to provide maximum lagoon
storage for the winter.
The lagoon ligizid lcvel should newer be closer than 1 foot to the lowest
point of the dam or embankment.
Do not pump the lagoon liquid level lower that the permanent storage
level unless you are removing sludge.
Locate float pump intakes approximately 18 inches underneath the liquid
surface and as far away from the drainpipe inlets as possible.
Prevent additions of bedding materials, long-stemmed forage or vegetation,
molded feed, plastic syringes, or other foreign materials into the lagoon.
Frequently remove solids from catch basins at end of confinement houses or
wherever they are installed.
Maintain strict vegetation, rodent, and varmint control new lagoon edges.
Do not allow trees or large bushes to grow on lagoon dam or embankment.
Remove sludge from the Iagoon either when the sludge storage capacity is
full or before it fills 50 percent of the permanent storage volume.
If animal:production is to be terminated, the owner is responsible for
obtaining and implementing a closure plans to eliminate the possibility of a
pollutant discharge.
Sludge Removal:
Rate of lagoon sludge buildup can be reduced by:

o8/05/98 12:54 $9102962122 tzSDA NRCS
€m 005
proper lagoon sizing,
mechanical solids separation of flushed waste,
gravity settling of flushed waste solids in an appropriately designed basin, or
minimizing feed wastage and spillage.
Lagoon sludge that is removed annually rather than stored long term will:
have more nutrients,
have more odor, and
require more land to properly use the nutrients.
Removal techniques:
Rim a custom applicator.
Mix the sludge and lagoon liquid with a chopper -agitator impeller
pump through large -bore sprinkler irrigation system onto nearby cropland;
and soil incorporate_
Dewater the upper part of lagoon by irrigation onto nearby cropland or
forageland; mix remaining sludge; pump into Liquid sludge applicator; haul
and spread onto cropland or forageland; and soil incorporate.
Dewater the upper part of lagoon by irrigation onto nearby cropland or
forageland; dredge sludge from lagoon with dragline or sludge barge; berm
an area beside lagoon to receive the sludge so that liquids can drain -back
into lagoon; allow sludge to dewater; haul and spread with manure spreader
onto cropland or forageland; and soil incorporate.
Regardless of the method, you must have the sludge material analyzed for waste
constituents just as you would your lagoon water. The sludge will contain different
nutrient and metal values from the liquid. The application of the sludge to fields will be
limited by these nutrients as well as any previous waste applications to that field and crop
requirement. Waste application rates will be discussed in detail in Chapter 3.
When removing sludge, you must also pay attention to the liner to prevent damage. Close
attention by the pumper or drag -line operator will ensure that the lagoon liner remains
intact. If you see soil material or the synthetic liner material being disturbed, you should
stop the activity immediately and not resume until you are sure that the sludge can be
removed without liner injury. If the liner is damaged it moist be repaired as soon as
possible.
Sludge removed from the Iagoon has a much higher phosphorus and heavy metal content
than liquid. Because of this it should probably be applied to land with.low phosphorus
and metal levels, as indicated by a soil test, and incorporated to reduce the chance of
erosion. Note that if the sludge is applied to fields with very high soil -test phosphores, it
should be applied only at rates equal to the crop removal of phosphorus. As with other
wastes, always have your lagoon sludge analyzed for its nutrient value.
The application of sludge will increase the amount of odor at the waste application site.
Extra precaution should be used to observe the wind direction and other cnnrlitions which
could increase the concern of neighbors.

O8/05/98 12:56 '$9102962122
USDA NRCS (a) 006
Possible Causes of Lagoon Failure
Lagoon failures result in the unplanned discharge of wastewater from the structure. Types
of failures include leakage through the bottom or sides, overtopping, and breach of the
dam. Assuming proper design and construction, the owner has the responsibility for
ensuring structure safety. Items which may lead to lagoon failures Include:
Modification of the lagoon structure ---an example is the placement of a pipe
in the dam without proper design and construction. (Consult an expert in
lagoon design before placing any pipes in dams.)
Lagoon liquid levels ---high levels are a safety risk.
Failure to inspect and maintain the dam.
Excess surface water flowing into the lagoon.
Liner integrity ---protect from inlet pipe scouring, damage during sludge
removal, or rupture from lowering lagoon liquid level below groundwater
table.
NOTE- If lagoon water is allowed to overtop the dam, the moving water will soon cause
gullies to form in the darn. Once this damage starts, it can quicldy cause a large discharge
of wastewater and possible dam failure.

'
Operator:MARVIN EVANS County: BRUNSWICK
Date:
01/05/93
.Distance
to nearest residence (other
than
owner):
2000.0
feet
1. STEADY STATE LIVE WEIGHT
0
saws (farrow to finish)
x
1417
lbs. =
01lbs
0
sows (farrow to feeder)
x
522
lbs.
0
lbs
0
head (finishing only)
x
135
lbs.
0
The
0
sows (farrow to wean)
x
433
lbs. a
0
lbs
3552
head (wean to feeder)
x
30
lbs. =
106560
lbs
TOTAL STEADY STATE LIVE WEIGHT (SSLW) = 106560 The
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 106560 lbs. SSLW x Treatment Volume(CF)/lb. SSLW
Treatment Volume(CF)/lb. SSLW= 1 CF/lb. SSLW
Volume = 1 106560 cubic feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0.0 cubic feet ; "Owner requests no sludge storage.
Sludge will be removed as needed."
4. TOTAL DESIGN VOLUME
Inside top length 220.0 feet ; Inside top width 135.0 feet
Top of dike at elevation 53.9 feet
Freeboard 1.0 feet ; Side slopes 3.0 : 1 (Inside lagoon)
Total design lagoon liquid level 'at elevation 52.9 feet J ,�
Bottom of lagoon elevation -2.9 feet Sp '4 W 42
Seasonal high water table elevation 49.9 feet Lf'
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH
3.0 3.0 3.0 3.0 214.0 129.0 10.0
AREA OF TOP
LENGTH * WIDTH =
214.0 129.0 27606.0 (AREA OF TOP)
.j
v
AREA OF BOTTOM J,
LENGTH * WIDTH
154.0 69.0 10626.0 (AREA OF BOTTOM)
AREA OF MIDSECTION
LENGTH * WIDTH * 4
184.0 99.0 72864.0 (AREA OF MIDSECTION * 4)
t
CU. FT. _ $AAREA TOP + (4*AREA MIDSECTION) + AREA BOTTOMO * DEPTH/6
27606.0 72864.0 10626.0 1.7

VOLUME OF LAGOON AT TOTAL DESIGN LIQUID LEVEL = - 185160 CU-. FT.
3
S. TEMPORARY STORAGE REQUIRED i
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width -
220.0 135.0 29700.0 square feet
Buildings (roof and lot water)
Length * Width -
0.0 0.0 0.0 square feet
TOTAL DA 29700.0 square feet
Design temporary storage period to be 180 days.
5A. Volume of waste produced
Approximate daily production of manure in CF/LB SSLW 0.00136
Volume - 106560 Lbs. SSLW * CF of Waste/Lb./Day * 180 days
Volume = 26023 cubic feet
5B. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume = 0.0 gallons/day * 180 days storage/7.48 gallons
per CF
Volume = 0.0 cubic feet
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180.days excess rainfall - 7.0 inches
Volume - 7.0 in * DA / 12 inches per foot
Volume = 17325.0 cubic feet

r
5D. Volume of 25 year - 24 hour storm
,.,a tN se 6,D i.)c L c� i ar gru .r3 w rt L( C Q
Volume = 7.5 inches / 12 inches per foot * DA
Volume = 18562.5 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 26023 cubic feet
58. 0 cubic feet
5C. 17325 cubic feet
5D. 18563 cubic feet
TOTAL 61910 cubic feet
6. SUMMARY
Total required volume 168470 cubic feet
Total design volume avail. 185160 cubic feet
Min. req. treatment volume plus sludge accumulation 106560 cubic feet
At elev. 50.-1-feet ; Volume is 116776 cubic feet (end -pumping,)
Total design volume less 25yr-24hr storm is 166598 cubic feet
At elev. 52:.Ttfeet ; Volume is 165029 cubic feet (startzpumping)
Seasonal high water table elevation 4 -.-39 feet
7. DESIGNED $Y:� APPROVED BY:
DATE: q, e{L DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN

SPECIFICATIONS FOR CONSTRUCTION OF WASTE TREATMENT LAGOONS
----------------------------------------------------------
Clearing:
All trees and brush shall be removed from the construction area
before any excavating or fill is started. Stumps will be removed
within the area of the foundation of the embankment and fill areas
and all excavated areas. All stumps and roots exceeding one (1)
inch in diameter shall be removed to a minimum depth of one (1)
foot. Satisfactory disposition will be made of all debris. The
foundation area shall be loosened thoroughly before placement of
embankment material.
Cut-off Trench:
---------------
A cut-off trench (when specified) shall be installed as shown in
the plans . C'u - a �i- Tc.-p c vcci c, c(
Construction:
Construction of excavated and earthfill areas shall be performed to
the neat lines and grades as planned. Deviations from this will
require prior approval of the SCS. Earthfill shall not be placed
in standing water and reasonable compaction of the fills shall be
performed by the construction equipment or sheeps-foot roller during
placement. The embankment of the lagoon shall be installed using
the more impervious materials. Construction of fill heights shall
include ten (10) percent for settlement. To protect against seepage,
when areas of unsuitable material are encountered, they will need to
be excavated a minimum of one (1) foot below grade and backfilied and
compacted with a suitable material (ie-CL,SC,CH). Refer to the soils
investigation information in the plans for special considerations.
Precautions should be taken during construction to prevent excessive
erosion and sedimentation.
Vegetation:
All exposed embankment and other bare constructed areas shall be
seeded to the planned type of vegetation as soon as possible after
construction.
LAB 0" htikx- smolt L#e c-oRtd down + o c(d vwk-AtouA( AAd W%ck,
�-it�d us.�.l��SA d c$vA{�'`� s�►�lD ciM.� �n�� �.h�
GUr t 64 u gs-*VNd

OPERATION AND MAINTENANCE PLAN
This lagoon is designed for waste treatment with minimum odor
control. The time required for the planned fluid level to be
reached may vary due to soil conditions,flushing operations, and
the amount of fresh water added to the system.
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent runoff from the field or damage
to crops.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre -
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see Attachment B)
before land application.
3. Begin pump -out of the lagoon when fluid level reaches eleva-
tion 52.1 as marked by permanent markers. Stop pump -out when
the fluid level reaches elevation 50.1 or before fluid depth is
less than 6 feet deep (this prevents the lose of favorable
bacteria) .
4. The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended maximum application rate is 0.4
inch per hour.
S. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
outlets.
8. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.

SEEDING RECOMMENDATIONS
-----------------------
AREA TO BE SEEDED: 2.0 ACRES
USE THE SEED MIXTURE INDICATED:
0 LBS. FESCUE GRASS S 60 LBS./ACRE
(BEST SUITED ON CLAYEY OR WET SOIL CONDITIONS)
SEEDING DATES: SEPTEMBER 15 TO NOVEMBER 30
0 LBS. •PENSACOLA' BAHIA-GRASS S 60 LBS./ACRE
(SEE FOOTNOTE NO. 1)
SEEDING DATES: MARCH 15 TO JUNE 30
16 LBS. HULLED BERMUDA GRASS 5 8 LBS./AC.
(SUITED FOR MOST SOIL CONDITIONS)
SEEDING DATES: APRIL 1 TO DULY 31
0 LBS. RYE -GRAIN S 30 LBS./ACRE (NURSERY FOR FESCUE)
0 LBS. RYE GRASS S 40 LBS:/ACRE (TEMPORARY VEGETATION)
SEEDING DATES: DECEMBER 1 TO MARCH 30
LBS.
APPLY THE FOLLOWING:
2000-LBS. OF 10-10-10 FERTILIZER (1000 LBS./ACRE)
4 TONS OF DOLOMITIC LIME (2 TONS/ACRE)
200 BALES OF SMALL GRAIN STRAW (100 BALES/ACRE)
ALL SURFACE DRAINS SHOULD BE INSTALLED PRIOR TO SEEDING. SHAPE
ALL DISTURBED AREA IMMEDIATELY AFTER EARTH MOVING IS COMPLETED.
APPLY LIME AND FERTILIZER THEN DISK TO PREPARE A 3 TO 4 INCH
SMOOTH SEEDBED. APPLY SEED AND FIRM SEEDBED WITH A CULTIPACKER
OR SIMILAR EQUIPMENT. APPLY MULCH AND SECURE WITH A MULCH
ANCHORING TOOL OR NETTING.
1. PENSACOLA BAHIAGRASS IS SLOWER TO ESTABLISH THAN COMMON .
BERMUDA GRASS. WHEN USING BAHIA, IT IS RECOMMENDED THAT 8
LBS./ACRE OF COMMON BERMUDA BE INCLUDED TO PROVIDE COVER
UNTIL BAHIAGRASS IS ESTABLISHED.

l . STEADY STATE LIVE WEIGHT
0
Sows
(farrow to f ii
7
lbs. =
0
0
Sows
(farrow to fee
?
lbs. =
0
0
Head
(finishing oniy)
X 135
lbs. -
0
0
Sows
(farrow to wean)
X 433
lbs. =
0
3552
Head
(wean to feeder)
X 30
lbs. =
106560
TOTAL STEADY STATE LIVE WEIGHT (SSLW) = 106560
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 106560 lbs. SSLW X Treatment Volume CF/lb. SSLW
Treatment Volume CF/lb. SSLW= 1.0 CF/lb. SSLW
Volume = 106560 cubic feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0 cubic feet
4. TOTAL DESIGN VOLUME
3
Inside top: length 206 feet ;r width 132 feet
Top of dike at elevation 53.-Jk0 feet 2,•;-
Freeboard 1.0 feet Side slopes-3^.1(inside)
Total design lagoon liquid level at elevation,�052.90 feet
Bottom of lagoon at elevation feet
Seasonal high water table elevation 4 .90 feet
Total design volume using prismoidal formula:
SS/END1 SS/END2 SS/SIDE1 SS/END2 LENGTH WIDTH DEPTH
2.5 2.5 2.5 2.5 201.0 127.0 10.00
AREA OF TOP
LENGTH X WIDTH
201 127
AREA OF BOTTOM
LENGTH X WIDTH =
151 77
AREA OF MIDSECTION
LENGTH X WIDTH X 4
176 102
25527 (Area of Top)
11627 (Area of Bottom)
71808 (Area of Midsection X 4)
CU. FT. = [Area top+(4XArea Midsection)+Area Bottom] X Depth/6
25527 71808 11627 2
VOL. OF LAGOON AT TOTAL DESIGN LIQUID LEVEL = 181603 CU. FT.
�07-6-

A i
5. TEMPORARY STORAGE REQUIRED
Drainage Area:
Lagoon (top of dike)
Length X Width =
206 132 27192 Square Feet
Buildings (roof and lot water)
Length X Width =
0 0 0 Square Feet
TOTAL DA 27192 Square Feet
===> Design temporary storage to be 180 days.
A. Volume of waste produced
Approximate daily production of manure in CF/LB SSLW 0.00136
Volume = 106560 Lbs. SSLW X CF of waste/lb/day X 180
Volume = 26086 Cubic feet
B. Volume of wash water
This is the amount of fresh water used for washing floors or
volume of fresh water used for a flush system. Flush systems
that recirculate the lagoon water are accounted for in 5A.
Volume = 0 Gallons/day X 180 days storage/7.48
gallons per CF
Volume = 0 Cubic feet
C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by
largest amount.
180 days excess rainfall = 7.0 inches
Volume = 7.0 Inches X DA / 12 inches per foot
Volume = 15862 Cubic feet
D. Volume of 25 year - 24 hour storm
Volume = 8.0 inches / 12 inches per foot X DA
Volume = 18128 Cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 26086 Cubic feet
5B. 0 Cubic feet
5C. 15862 Cubic feet

5D. 18128 Cubic feet
TOTAL 60076 Cubic feet
6. SUMMARY
Total required volume = 166636 Cubic feet
Total design volume avail.= 181603 Cubic feet
Min. regrd. trtmnt. vol. plus sludge accum.= 106560 Cu. Ft.
At elev. 50.10 Ft; Vol= 116374 Cubic feet (end pumping)
Total design volume less 25yr-24hr storm = 163475 Cu. Ft.
At elev. 52.10 Ft; Vol= 161702 Cubic feet (start pumping)
Seasonal high water table elevation is 49.90 Feet, which must
be lower than the elevation of top of treatment volume 50.10
DESIGNED BY: APPROVED BY:
DATE:
DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
ADDITIONAL NOTES:

I i 4 II II ij Ijl -II I } r
L 1
It 15"
Au
i IJ- 14�i 1
s L J Iji
a. d
L! I
__ _'. ­.-1 -1 . I . : j

,
of butr ients or other elements. Your production facility will produce
,�I approximately 269.952 pounds of plant available nitrogen per year in the
sludge.
If you remove the sludge every 5 years,' you will have approximately 1349.76
pounds of PAN to utilize. Assuming you apply this PAN to hybrid
bermudagrass hayland at the rate of 300 pounds of nitrogen per acre, you
will need 4.4992 acres of land. If you apply the sludge to corn at
the rate of 125 pounds of nitrogen per acre, you will need 10.79808 acres
of land. Please be aware that these are only estimates of the PAN and
land needed. _Actual requirements could vary by 25% depending on your
sludge waste analysis, soil types, realistic yields, and application
methods .
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the
soil at the time of irrigation such that runoff or ponding occurs. This
rate is limited by initial soil moisture content, soil structure, soil
texture, water droplet size, and organic solids. The application amount
should 'not exceed the available water holding capacity of the sail at the
time of irrigation nor should the plant available nitrogen applied exceed
the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables 1 and 2. Failure to apply the recommended rates and
----------------------------------------------------------------------
Page: 6
ANIMAL WASTE U ION PLAN
amounts of nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application
rates and amounts.
Application Rate
Applic. Amount
Tract
Field
Soil Type
Crop
(in/hr)
(inches)
v�
492
3
Wo
FP
0.4
j,0
492
4
WO
FP
0.4
ra
493
1
FO
BP
.5
*. 9 5 �tish�
jP

491 r 2 FO
*0.95
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations, the application amount shown cannot
beapplied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180.00 days of temporary storage and the
temporary storage must be removed on the average of once every 6.00 months.
In no -instance should the volume of the waste be stored in your stracture.
be within the 25 year 24 hour storm storage or one foot of freeboard except
in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure
that the spreader equipment is operated properly to apply the correct rates
to the acres shown in Tables 1 and 2. Failure to apply the recommended
rates and amounts of nitrogen shown in the tables may make this plan
invalid.
Call your technical specialist after you receive the waste analysis report
for assistance in determining the amount of waste per acre and the proper
application rate prior to applying the waste.
NARRATIVE OF OPERATION
0
---------------------------- -------------------------------------
a Page: 7
WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does

Sl.ate of North Carolina
r Department of Environment
and Natural Resources
Division of Water Quality
Michael F. Easley, Governor
Sherri. Evans -Stanton, Acting Secretary
Kerr T.- Stevens, Director
January 26, 2001
MARVIN EVANS
JUNIPER CREEK
6889'PARKER ROAD, NW
ASH NC 28420
A4"•
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Application No. AWS 100029
Additional Information Request
Juniper Creek
Animal Waste Operation
Brunswick County
Dear Mr. Evans:
The Non -Discharge Permitting Unit has completed a preliminary engineering review of the
subject application. We just need one more item to complete your review. Additional information is
required before we can continue our review. Please address the following by February 25, 2001:
Please amend the irrigation parameters listed in your Waste Utilization Plan (WUP)
on page 6. The listed application amount in inches exceeds the current
recommendations of one (1) inch per application event. I have enclosed a copy of
this page for you to amend.
Irrigation events are to be listed in the WUP as the maximum application allowable
for that soil type from the time the pumps are turned on until the time they are shut
off. The application events listed in your WUP appear qtb outof the Sprinkler
Irrigation Guide. The Application Amounts lis de have not been
adjusted for the application of animal w is ently recommended that total
application amounts not exceed one inc in ication event for any soil type. If
your application rates need to be adjuste r the application of animal waste, please
have your Technical Specialist revise your WUP to reflect the appropriate application
amount per event. If the rates exceed the recommended one inch, please have
your Technical Specialist justify the increased application rate in the narrative
of your WUP.
Please note that all WUP revisions must be signed and dated by both the owner and the
technical specialist.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617
An Equal Opportunity Affirmative Action Employer
RECEIVED
WATFR rl IAl I1Y SECTION
FEB 2 u 2001
Telephone [phone] FAX [phone]
50% recycled/ 10% post -consumer paWn_[)i
8 N11Ytlttlrlg

Application No. 10-0029
. -• Page 2
Please reference the subject permit application Dumber when providing the requested
information. All information should be signed, sealed, and submitted in duplicate to my attention at the
address below_
NCDENR-Non Discharge Permitting Unit (attn: Theresa Nartea)
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
The information requested by this letter must be submitted on or before February 25, 2001 or
the Division will return your application as incomplete in accordance with 15A N.C.A.C. 2H .0200 and
your facility will be considered to be operating without a permit_
Please be advised that operation of the subject animal waste management system without a valid
permit is a violation of North Carolina General Statute 143-215.1 and will subject you to the
enforcement authority of the Environmental Management Commission.
If you have any questions regarding this request, please call me at [phone], ext. 375.
Sincerely,
Theresa Nartea
Nartea
Soil Scientist
Non -Discharge Permitting Unit
cc: Wilmington Regional Office, Water Quality
Permit File

of nutrients
"approximately
sludge.
or other elements. Your production facility will produce
269.952 pounds of plant available nitrogen per year in the
If you remove the sludge every 5 years,' you will have approximately 1349.76
pounds of PAN to utilize. Assuming you apply this PAN to hybrid
bermudagrass hayland at the rate of 300 pounds of nitrogen per acre, you
will need 4.4992 acres of land. If you apply the sludge to corn at
the rate of 125 pounds of nitrogen per acre, you will need 10.79808 acres
of land. Please be aware that these are only estimates of the PAN and
land needed. Actual requirements could vary by 25% depending on your
sludge waste analysis, soil types, realistic yields, and application
methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the
soil at the time of irrigation such that runoff or ponding occurs. This
rate is limited by initial soil moisture content, soil structure, soil
texture, water droplet size, and organic solids. The application amount
should not exceed the available water holding capacity of the soil at the
time of irrigation nor should the plant available nitrogen applied exceed
the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan,
it is the responsibility of the producer and irrigation designer.to ensure
that an irrigation system is installed to_properly irrigate the acres
shown in Tables 1 and 2. Failure to apply the recommended rates and
Page: 6
D
00 00
0
ANIMAL WASTE UTILIZATION PLAN
amounts of nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application
rates and amounts.
Application Rate
Applic. Amount
Tract
Field
Soil Type
Crop
(in/hr)
(inches) �
V
492
3
WO
FP
0.4
_*��3 1,0
492
4
WO
FP
0.4
*1.3— +
493
1
FO
BP
.5
*. 9 5
.0

49 2 FO
*0.95
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations, the application amount shown cannot
be.applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180.00 days of temporary storage and the
temporary storage must be removed on the average of once every 6.00 months.
In no instance should the volume of the waste be stored in your stracture
be within the 25 year 24 hour storm storage or one foot of freeboard except
in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure
that the spreader equipment is operated properly to apply the correct rates
to the acres shown in Tables 1 and 2. Failure to apply the recommended
rates and amounts of nitrogen shown in the tables may make this plan
invalid.
Call your technical specialist after you receive the waste analysis report
for assistance in determining the amount of waste per acre and the proper
application rate prior to applying the waste.
NARRATIVE OF OPERATION
Page: 7
WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does

10 - Z61
{ 5
Mate`of North Carolina
Department of Environment •
and Natural Resources
Division of Water Quality RECEIVED
Michael F. Easley, Governor
� FEB os zoos
Sherri Evans -Stanton, Acting Secretary NCDENR
Kerr T. Stevens, Director NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
January 26, 2001
MARVIN EVANS
JUNIPER CREEK
6889 PARKER ROAD, NW
ASH NC 28420
Subject: Application No. AWS 100029
Additional Information Request
Juniper Creek
Animal Waste Operation
Brunswick County
Dear Mr. Evans:
The Non -Discharge Permitting Unit has completed a preliminary engineering review of the
subject application. We just need one more item to complete your review. Additional information is
required before we can continue our review. Please address the following by February 25, 2001:
Please amend the irrigation parameters listed in your Waste Utilization Plan (WUP)
on page 6. The listed application amount in inches exceeds the current
recommendations of one (1) inch per application event. I have enclosed a copy of
this page for you to amend.
Irrigation events are to be listed in the WUP as the maximum application allowable
for that soil type from the time the pumps are turned on until the time they are shut
off. The application events listed in your WUP appear to be out of the Sprinkler
Irrigation Guide. The Application Amounts listed in this guide have not been
adjusted for the application of animal waste. It is currently recommended that total
application amounts not exceed one inch in any application event for any soil type. If
your application rates need to be adjusted for the application of animal waste, please
have your Technical Specialist revise your WUP to reflect the appropriate application
amount per event. If the rates exceed the recommended one inch, please have
your Technical Specialist justify the increased application rate in the narrative
of your WUP.
Please note that all WUP revisions must be signed and dated by both the owner and the
technical specialist.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

i
Application No. 10-0029
Page 2
Please reference the subject permit application number when providing the requested
information. All information should be signed, sealed, and submitted in duplicate to my attention at the
address below.
NCDENR-Non Discharge Permitting Unit (attn: Theresa Nartea)
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
The information requested by this letter must be submitted on or before February 25, 2001 or
the Division will return your application as incomplete in accordance with 15A N.C.A.C. 2H .0200 and
your facility will be considered to be operating without a permit.
Please be advised that operation of the subject animal waste management system without a valid
permit is a violation of North Carolina General Statute 143-215.1 and will subject you to the
enforcement authority of the Environmental Management Commission.
If you have any questions regarding this request, please call me at [phone], ext. 375.
Sincerely,
J
Theresa Nartea
Soil Scientist
Non -Discharge Permitting Unit
cc c=- -Wilmington Regional Office, Water Quality -
Permit File

State of North Carolina
Department of Environs
and Natural Resources
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Marvin Evans
Juniper Creel:
6656 Mrytle Head Road
Ash NC 28420
Dear Marvin Evans:
EIVRD �4�
11 2000 0 •
J d
9CDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RE50URCE5
October 2, 2000
Subject: Notification for Wettable Acre Determination
Animal Waste Management System
Juniper Creek
Facility Number 10-29
Brunswick County
A letter dated January 15, 1999 was sent to advise you about concerns associated with Certified Animal
Waste Management Plans and the method by which the irrigated acres within the plans were calculated. Only
the acres that are wetted can be credited in the waste management plan as receiving waste application. Any
acreage within the plan that can not be reached by waste application equipment can not be used as part of your
plan.
An evaluation by Audrey Oxendine on 8/23/99 was made to review the actual number of acres at your
facility that receive animal waste during land application. The evaluation of your facility has yielded one of
the following two results as indicated by the box marked with an "X".
Cate o y 1:
The evaluation of your facility could not be completed due to a lack of information. Please
contact your Technical Specialist to assist in providing John. College the necessary
information to potentially exempt your facility from undergoing a complete wettable acre
determination. Please submit this information to John College, at 127 Cardinal Drive
Extension, Wilmington, NC 28405-3845, within in 90 days of the receipt of this letter. If you
have any Questions please contact John College at [phone]. If within 90 days you
are unable to provide John College with the information you are automatically
required to complete a Wettable Acre Determination as described by Category 2
below, within 180 days of receipt of this letter.
1617 Mail Service Center, Raleigh, North Carolina 27699-I617 Telephone [phone] - Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

.r
Notification for Wettable Acre Determination
Animal Waste Management System
Page 2
Category 2:
❑ Your facility has been identified by the Department of Environment and Natural Resources
as a facility that may have overestimated the number of acres actually receiving animal
waste. Therefore, some or all of your fields may be exceeding the allowable loading rates
set in your Certified Animal Waste Management Plan.
In order to resolve this issue, please contact a designated Technical Specialist to have him
or her conduct a Wettable Acre Determination for your facility. The Technical Specialist must
be one that has been approved by the Soil and Water Conservation Commission to conduct
Wettable Acre Determinations. Many Technical Specialist with the N.C. Cooperative Extension
Service, the Soil and Water Conservation Districts, the Natural Resources Conservation
Service, and the Division of Soil and Water Conservation have received this special
designation. You may also contact a private Technical Specialist who has received this
designation, or a Professional Engineer.
All needed modifications to your Animal Waste Management System must be made and
the Wettable Acres Determination Certification must be returned to DWQ within the next
180 days. If the needed modifications are not made and if the form is not returned within the
required time, DWQ will be forced to take appropriate enforcement actions to bring this facility
into compliance. These actions may include civil penalty assessments, permit revocation,
and/or injunctive relief.
Once a Wettable Acre Determination has been completed, a copy of the attached Wettable
Acre Determination Certification must be submitted to the address listed on the form. Please
note that both the owner and the Technical Specialist must sign the certification. A copy of all
the Wettable Acre Determination documentation that applies to your Waste Utilization Plan
must be kept at your facility. DWQ and the Division of Soil & Water Conservation Staff will
review all documentation during their annual visit of your facility. An additional copy must by
kept on file at the local Soil & Water Conservation District Office. Please note that if you install
or modify your irrigation system, a designated Irrigation Specialist or a Professional Engineer
must also sign the Wettable Acre Determination Certification.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Sonya Avant of our
Central Office staff at [phone] ext. 571.
Sincerely,
N - 0- V - 3 t 0-0
Kerr T. Stevens
cc: Wilmington Regional Office
Brunswick County Soil and Water Conservation District
Facility File

State of North Carolina _
Department of Environment ��=�� �= a •
and Natural Resources OCT 2 5 CuuJ
Division of Water Quality
B:NCDENR James B. Hunt, Jr., Governor
Bill Holman, Secretary Now I CAROLfNA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Kerr T. Stevens, Director
October 23, 2000
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Marvin Evans
Juniper Creek
6656 Mrytle Head Road
Ash NC 28420
Farm Number: 10 - 29
Dear Marvin Evans:
You are hereby notified that Juniper Creek, in accordance with G.S. 143-215.10C, must apply for coverage under an
Animal Waste Operation General Permit. Upon receipt of this letter, your farm has sixty (60) days to submit the attached
application and all supporting documentation. In accordance with Chapter 626 of 1995 Session Laws (Regular Session
1996), Section 19(c)(2), any owner or operator who fails to submit an application by the date specked by the
Department SHALL NOT OPERATE the animal waste system after the specified date. Your application must be
returned within sixty (60) days of receipt of this letter. Failure to submit the application as required may also subject your
facility to a civil penalty and other enforcement actions for each day the facility is operated following the due date of the
application.
The attached application has been partially completed using information listed in your Animal Waste Management
Plan Certification Form. If any of the general or operation information listed is incorrect please make corrections as noted on
the application before returning the application package. The signed original application, one copy of the signed application,
two copies of a general location map, two copies of the Certified Animal Waste Management Plan must be returned to
complete the application package. The completed package should be sent to the following address:
North Carolina Division of Water Quality
Water Quality Section
Non -Discharge Permitting Unit
1617MaiI Service Center
Raleigh, NC 27699-1617
If you have any questions concerning this letter, please call Theresa Nartea at [phone] extension 375 or
Stoney Matthis with the Wilmington Regional Office at [phone].
erely, ,
for Kerr T. Stevens
cc: Permit File (w/o encl.)
Wilmington Regional Office (w/o encl.)
1617 Mail Service Center, Raleigh, NC 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
Marvin Evans
Juniper Creek
6656 Mryde Head Road
Ash NC 28420
Dear Marvin Evans:
IT1IfflIW'J
� •
A2
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
December 30, 1999
Subject: Fertilizer Application Recordkeeping
Animal Waste Management System
Facility Number 10-29
Brunswick County
This letter is being sent to clarify the recordkeeping requirement for Plant Available Nitrogen (PAN)
application on fields that are part of your Certified Animal Waste Management Plan.
In order to show that the agronomic loading rates for the crops being grown are not being exceeded, you
must keep records of all sources of nitrogen that are being added to these sites. This would include nitrogen
from all types of animal waste as well as municipal and industrial sludges/residuals, and commercial fertilizers.
Beginning January 1, 2000, all nitrogen sources applied to land receiving animal waste are required to
be kept on the appropriate recordkeeping forms (i.e. 1RR1, IRR2, DRYI, DRY2, DRYS, SLURI, SLUR2,
SLD1, and SLD2) and maintained in the facility records for review. The Division of Water Quality (DWQ)
compliance inspectors and Division of Soil and Water operation reviewers will review all recordkeeping during
routine inspections. Facilities not documenting all sources of nitrogen application will be subject to an
appropriate enforcement action.
Please be advised that nothing in this fetter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Ms. Sonya Avant of the
DWQ staff at [phone] ext. 571.
Sincerely,
a�
Kerr T. Stevens, Director
Division of Water Quality
cc: Wilmington Regional Office
Brunswick County Soil and Water Conservation District
Facility File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recyded/10%o post -consumer paper

%0 -Zq
Ash, NC 28420
August 7, 1998
Mr. Dean A. Hunkele
Environmental Specialist
Dept. of Environment and Natural Resources_
127 N. Cardinal Drive
Wilmington, NC 28405
Re: Certified Mail # Z 312 646 162
Inspection July 16, 1998
I
AUG 11 1998
We were furnished a copy of your letter by Carroll Foods before we
were notified by the Post Office that we also had been sent a
certified letter.
We assured the inspector on his visit that it was our intentions
to comply as closely as possible with all regulations. Some of the
deficiencies sighted in the letter were not mention at the time of
inspection. However, we have and are making every effort to
correct the noted deficiencies.
We now have an up-to-date waste analysis. We have made adjustments
in our calculations on the lagoon records to reflect the correct
PAN.
We now have a form to record weekly lagoon levels, and we are using
it.
The information from records have been transferred to the IRR 1 &
2 forms. Mr. Ricks is getting, for us, the software package from
the state for waste -management records.
From the beginning, our spray field was set up to be grazed by
cattle. We are not real sure how cows could possibly graze without
utilizing the area. The bare areas (two in fact) are questionable
as to allowing sediment to enter adjacent ditches to the field.
(1) bare area: the west corner is much higher than the surrounding
area and sloped in_a manner that runoff runs back into the field.
Though it is inside the perimeter fence, it is not part of the 14
acres assigned for spraying and is not sprayed. It is a stockpile
of soil for future building pads. It is not good soil and for the
purpose intended does not have to be. It is disc at regular
intervals and seeded. Also, we have been able to get a growth of
grass started because of the discing, seeding, and occasionally
feeding coastal Bermuda hay to the cows on this area.
The left -over hay is incorporated into the soil by discing, lime

and fertilizer are spread before discing. It is slow, but we are
continually trying, with hopeful results. There is a beginning
crop of grass on this area.
(2) bare area: since it is necessary to water livestock, we have
a concrete water trough in the pasture from which the cows drink.
There is an area of about eight feet surrounding the trough, the
cows have stomped the grass off. The water is fresh water
furnished by an underground line from the well to the trough. On
occasion the trough is unattended longer than we intended, and it
over -flows. To alleviate this problem we have placed, in the
trough, a float that cuts off the water at a level that does not
allow over -flowing. Also, we are going to move the trough away
from the low area and install a small berm in front to stop run-
off from around the water trough.
Representatives from Carroll Foods visited August 4, 1998,
inspected the property, and discuss the deficiencies sighted.
Suggestions were made by them as to correcting problem areas and
record -keeping. They also supplied forms, information, and
contacts for help. Their visit was very. informative and we are
following their suggestions.
We have also discussed this letter and other concerns related to
regulations and compliance with Mr. Phil Ricks of the Extension
Service. He, also, has been very helpful to us in our efforts to
comply with regulations, -get information, and answer questions we
have.
There is one suggestion we would like to make. That is, that
guest, those person(s) not employed by the DENR, not accompany the
WQC inspectors on visits to our farm, unless we are notified, prior
to the visit that these "guest" may be expected.
Sincerely,
-Ir) �f &ZXA �/
i
Marvin L. Evans and Lucy R. Evans, Owners
Juniper Creek Farm
Facility Number: 10-29
Brunswick County
6656 Myrtle Head Rd., NW
Ash, NC 28420

AUG-10=98 TUE I0:27 PM MARVIN_L.EVANS 1919287569E
I
56 myrtle Head Rol, f NW
Ashy NO 28420
Telephone: [phone]
FAX a 10) 287-,5090
I F.
,Z) P- ti-TR
Phone:
Fax Phone:
Remarks.
Co1rrirtena:
CC
For
ri
P.01
P ep
,vurr�hrr ofEs� ages incluJl�tq c4tc+r s
¢
�" „ `
Cu»rpnit; -1
aAx 0,--
�4t;:l.Ae:.�
iew Reply ' ��S ycri�
Q4CA -LA -PS
�.
A, /� _�y ,
V t1%p�it_

AUG-10-98 TUE 10 :28 PM MARV�iN_L.. EVANS
1910'3_975
r_ 02
Mr. Dean A,
Envit'unmenl
Dept, of Er
127 N. Ca:rc
wi lmingtm,
HunkeIe
al 8peci,aI i;
vironment al
final Drive
Ne 20405
Re: c4rti.fied Mai
inspection JU
We were furnished a c
were notified by the
certified letter.
We assured the inspect.
to Comply as alosel.y► as
deficiencies sighted ii
]Inspection. However,
correct the noted defi
We now nave an up-to-da
in our cal ulations onPAN, . f
We now have a form to r
t . i
The inform tion from r
2 warms. Ir. Ricks is
the state or waste --ma
From the beginning, ou
cattle. We are not real
utilizing the area. Th
as to allowing sedimen
(1.) bare area: the west
area and sloped in a mz
Though it is inside the
acres a3sai ned for spry
of soil for future buil
purpose in ended does
intervals ad seeded.
grass star ed because
feeding co stal Dermud�
The left-o er hay is i
ajh, NC 20420
August 7, 1998
i
I
i
t
d I9a�11ral ReGnur•res
#I x 312 646 162
y 16 1998
y of �c%tir letter by Carroll
lost b ffice that we ilsi$ 1
or onj tits vis;I t. that it was
possfble with All ragilat'ic
the 11 -, Ef mr wAiA not motif l0
we lave and are jna-kinq
iencl es.
.e wa ta'anal,y�i�;� We,ha(e
the kgo'on 'rR0Qar."da ts..ecf l
cord ilweekl y 1A9 i,n l eve
cordl have togen t rarisfs'rreo
getting, for its, the aoftwi
agemgn re. -cords.
r sp ay field was set up
aux4 hoer Cows couia 00-CAA
barn, areas (two in fwrfl J
i to ;enter. adjaceiitd'i��;` tChe
corner. is much r_hi.ghc-)�. t ti
nner 'that- r'itiipf runs }xiit�k
pezi ots frn'c:e, t 17v.t:
ying ind is not sprayed_ 7'
ling ads. It is not good
not ave to be. It is
Also,; We have been able to
nof the discing, se -Wing, z
hay to the cows an thfi �
It!nr-p-irafPd into t cni l,: }
5odr, before v;o
I. been sent '
�gr 1ntont ion19
e of „eje"
Rt tkp time a
►Cy effort. to
�� arl� istlnRit�;;�
;t r�� 'corr'ryat
we sire
o the IRR 1
ri-
parkaa6 f r.nih
be grazed by
grfs7,4--wlthaut
�uestinnahli�
r, cti " t t� �+ r j e I d•
f i_
J14tl: l of t im'" T4
.s~ a �f:orlCpile+
l I slid• f or the
ac at_ •� regttl,�tr
t a growth of
occasibnalIy

AUG-10--98 TUE 10:28 PM MARVIN_L.EVANS
191026'750.9
P.03
and fertilizer
are spread
b�tore discing. it is
law,
but we are
vontinually
trying, with
hcIPeful results. Theres
a beginning
crop of gr
ss On this
area..
(2) bare a
ea: since
i
t is! neceGgar'y to water. l.i.
�I nak, we have
a concrete
water trou
h in ithe? patyture fvom whict
the
cows drink.
There .is ai
area of a
out 0-Ight feet silr, rounrltug
the.
trough, the
cows havC
tomped the
rassIoff. The water is trosh
wager 1
furnished
y an underg
ound:line Prom the well to
a trough. on
occasion t
e trough is
unat ended longer than we
intonded,
end it
over -flows
To alleviate
;this problem we have
11need,
fi) the
trough, a
11oat that cuts
olft the water at a level'
that does not
allow Pvcr
flowing, Plso,
;we are going to move
t:
f- trtmgh away
from the 1
w aroa and
'nstajl a small berm in fac
n:.
to vtop xuiA-4
off from a
ound the Water
trough.
={:.
Represents
ives from
Carr 11 Foods visited A
try
1st q, 1999,
Inspected
the propert
, a d discilGs the detici
Pl
r,i.OR ,. i.gilt ed,
Suggestion
S were made
6Y tl'em as te., corm''i:tnq I,'
tr
,iF.'•Etl !iT:F'r; ;:`Aim)
record-kee
ing. Tbey
al 0 Surplied forms, Int41C111Ak1011,,
Ahg
contacts f
r help. Their
Yisit was very inform
t.
ve'_ag4 we are
following:heir
sugges
ions:
we have al
rio discussed
this letter an,,! otlseer-;Cvii'i-
-iuj related t11
regulation
and compliance
!with ter': :Mail: Rinlzs
f
th,g Fli:+^1�ril�+s'a
service.
e, also, ha
bee' very hello 1 t� `u4' 1
sir nrt� t.t'
comply wit
P Y
regulation
9e information, at]d ins
� .t'
`
qUAA1:,oi1'1`?'Ig
have.
There is cne
suggestion
wtj woix10 1 tk•- to mAke...
ThigI. 1-4 I.laa1.
guest, those
Person(s)
not jrnployed by -the r)IRNR, njoi
'4`c4.jTjPR11y i ii0
WQC i.nspec
ors on visits
to our farm, unl ess we ar
ntIfipd, prier
to the vi.s
t that then
"guest" may he expected.
Sincerely,
Marvin L , vans sad T,u
Juniper Cz ek Farm
Facility N mber: 10-29
Brunswick aunty
6656 Myrt3420
Bead Rd.,
Ash, NO

f �Q
Z 912 64E. 1.62
US Postal Service
Receipt'for Certified Mail
No Insurance Coverage Provided.
Co not use for Intemational Mail lSaa ravarcai
Postage $
Certified Fee
SP8cW Delivery Fee
Restricted Delivery FeeLO
I !
Holum Receipt Showing to
Whom & Date Delivered E j
Reh- RWW Showing to Whom, k
Data. A Addressee's Address
WTOTAL Postage d
C9 Postmark or Da
cb

CERTIFIED
NC Department of Environment and Natural Reso
Wilmington Regional Office
t27 Cardinal Drive Extension 2T JUL
Z 312 646 -162
Wilmington, NC 28405
J
E HC 283 #1 lj..7/Z-*P,/98
N
N %J
vt
wj
H MET EIR 5 4 0 P, G
13 W Dowembie As Addressed
thl" To Forward
Mr. Marvin Evans 0 lrtsifflkleM Address
Juniper Creek Farm tt No ,address
MAIL
RE Elpr 2 ant
F%7 REC
RH STED
UE ecep a
0 Box Closed - No Order
0 Returned For Butter Ad*wW
it 11111 1 fit 111111111 ti 1111111ill 11 11111 11111 111111 111111111 111

o� ado�anuy �a a.a; -ie,jo allll 1e pj0A
m SENDER;_:_
` • Complete' Items 1 and/or 2 fad addttiorlal se ►3cea• -
'a
I also wish to recelve.the
S
■Complete deals 3, 4a, and V. ° .:, ". .
following services (for an
■ Print your name and address on the reverse of this form so Mat *9 can Mum this
card to you.
extra fee):
■Anach No form to the frond of the maltoace, or on the track if space does not
1. ❑ Addressee's Address
■ W rite'Retum Receipt Requested• on the maitpieoe below the article number.
2. ❑ Restricted Delivery
N
■The Return Receipt will show to whom the article was delivered and the date
delivered.
Consult postmaster for fee.
c
3. Article Addressed to:
N1aw, n5
4a. Article Number
Z 31 A (P
E
$
J off►: C
4b. Service Type
❑ Registeredertifled
j�
"s_.
�� ' 1 • !� 'L'��
❑ Express Mail ❑ Insured
❑ RelumReceiptfor Merchandise ❑ COD.
s -
7. Date of Delivery
3
v
T
5. Received By: (Print Name)
8. Addressee's Address (only if requested
G
-
and fee is paid)
n—.1drw aaa.N-Anant)
-
102595-97-"179
24 1998

State of North Carolina
Department of Environment
and Natural Resources
Wilmington Regional Office
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
Division of Water Quality
July 24, 1998
Certified Mail # Z 312 646 162
Return Receipt Re!ueged
Mr. Marvin Evans
Juniper Creek Farm
6656 Myrtle Head Road
Ash, NC 28420
AW
.•• AA
ji
RCDENR
NORTH CAROuNA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: SECOND NOTICE OF DEFICIENCY
Juniper Creek Farm
Facility Number: 10-29
Brunswick County
Dear Mr. Evans:
On July 16, 1998, staff from the Wilmington Regional Office of the Division of Water
Quality inspected your animal operation and the lagoon serving this operation. During the
inspection, it was observed that you had several items that require attention. First of all, irrigation
records were not readily available and irrigation records provided to this office after the inspection
are not correct. Secondly, bare areas in spray field #1 are allowing sediment to enter the ditches
adjacent to the field. Lastly, lagoon level records are not being kept.
As discussed at the time of the inspection, record keeping must be improved. A weekly
schedule must be established for keeping records of the lagoon level. Irrigation records sent to
this office after the inspection have a number of problems. It is fine to use a spreadsheet to aid
in keeping such records, but information must be transferred to the IRR forms in a timely manner
with up to date records kept on the farm. As for specific problems with records supplied to this
office, the following problems are duly noted. Monthly record for winter cover crop list coastal
bermuda when in fact this should be small grain as indicated in the waste plan. Most records fail
to list any crop at all. Incorrect Plant Available Nitrogen (PAN) loading rates are being used in
all records. Irrigation records must be revised immediately on approved IRR forms and in
accordance to the Waste Utilization Plan. Using the wrong PAN could result in an unintentional
over application of waste. Over application could result in a violation and would require a
reduction in the allowance for the next rotation.
127 North Cardinal Dr., Wilmington, North Carolina 28405 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

Page 2
Marvin Evans
July 24, 1998
Bare areas in spray field #1 are being caused by cattle utilizing the field. Such areas are high
use or loafing areas for the cattle with no vegetation covering the ground. Sediment is making its
way from these areas to ditches adjacent to the field. Cattle should be excluded from the bare area
along the ditch at the back of field to allow a vegetative buffer to be established. The watering
trough should be moved frequently enough to keep vegetation covering the ground. Placement
of the trough away from field edges will help reduce sediment leaving the field and entering the
grassed waterways and ditches.
You must notify this office. in writing within fourteen (14) days -of the receipt of this notice, .
what actions are being taken to correct these deficiencies. Failure to do so may result:in the facility
losing its deemed permitted status and being required to obtain an individual non discharge permit.
We suggest that you contact your service company, the local NRCS office, or the Soil and Water
District office for any assistance they may be able to provide to correct this situation.
Please be aware it is a violation of North Carolina General Statutes to discharge wastewater
to the surface waters of the State without a permit. The Division of Water Quality has the
authority to levy a civil penalty of not more than $10,000 per day per violation.
If you have any questions concerning this matter, please call David Holsinger, Brian Wrenn,
or Dean Hunkele at 910-395-3900.
Sincerely,
Dean A. Hunkele
Environmental Specialist
cc: Josh Spencer, Brunswick County Soil and Water Conservation
Sandra Weitzel, NC Division of Soil and Water Conservation
Phil Ricks, Brunswick Co. Cooperative Extension
Don Butler, Carrolls Food
Non -Discharge Branch
Wilmington Files
S.• IWQR4A7MALSIBR UNSWIC110-29-2. DEF
127 North Cardinal Dr., Wilmington, North Carolina 28405 Telephone [phone] FAX [phone]
An Equal opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

State of North Carolina
Department of Environment, Health, and Natural Resources
Wilmington Regional Office
James B. Hunt, Jr. Division of Water Quality Jonathan B. Howes
Governor
May 13, 1997
a -5U.: '1 1:
Mr. Marvin Evans
Juniper Creek Farm
6656 Myrtle Head Road
Ash, North Carolina 28420
Dear Mr. Evans:
Secretary
Subject: NOTICE OF DEFICIENCY
Juniper Creek Farm
Facility Number: 10-29
Brunswick County
On March 31, 1997, staff from the Wilmington Office of the Division of Water Quality inspected
your animal operation and the lagoon(s) serving this operation. It was observed that wastewater was present
in a roadside ditch adjacent to spray fields indicating a past discharge. While no discharge of waste was
observed to waters of the state at the time -of inspection, any rainfall event could likely result in the discharge
of waste from the ditch.
As was discussed during the inspection, the pipe which carries drainage from the irrigation fields
to the roadside ditch should be blocked while spraying or removed altogether. If possible, it is suggested
that the field ditch/waterway be filled to prevent future runoff of waste. In addition, the operator must keep
spray records to ensure that waste is being applied at proper agronomic and hydrologic rates. We suggest
that you contact your Iocaal NRCS or Soil and Water District for any assistance they may be able to provide
to correct this situation.
To remain a deemed permitted facility, all corrective actions must be made within fourteen (14)
days. Failure to do so may result in the facility losing it's deemed permitted status, requiring it to obtain
an individual non discharge permit.
127 Cardinal Drive Extension, Wilmington, N.C. 28405-3845 0 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer

ru
1rm
mv�CO
C3
Q =
'
d C
S) z
I
0
4fl
`
ti rn
m
CD
F
566 t IIa W ORBS ---I Scl
SENDER:
.0 ■ Comdata items t andlor 2 for addtttonal services.
I also wish to receive the
'a►
sComplete fterrn 3, 4a, and 4b.
following services (for an
m
V Print your name and address on the reverse of Oft form so that we can return thts
eXtra fee):
■Attach, � form to the front of the mailpiece, or on the back if space does not
1. ❑ Addressee's Address
m■
wri a •Reum Receipt Requested• on the mallpiece below the article number.
2. ❑ Restricted Delivery
I
The Retun Receipt will show to whom the article was delivered and the dale
cr
deltvered.
Consutt postmaster for fee.
3. Article Addressed to:
4a. Article Number
E
�� F]
b. Service Type
egistered Mfied
o
IM
ress Mail ❑Insured
Receipt for Memhandise COD
5
W
�J ��
��-�
m ❑
to of Delivery
�J^
5. Received fa): (Print Name)
In-/_7
Addressee's Address (Only if requested
and fee is paid)
t ;
{
8 Signs . (Addres"PwAaro~
m
P9 o 3811, mb r 1994
10259s47-e-0179 Domestic Return Receipt

Marvin Evans
May 13, 1997
Page 2
Please be aware it is a violation of North Carolina General Statutes to discharge wastewater to
the surface waters of the State without a permit. , The Division of Water Quality has the authority to levy
a civil penalty of not more than $10,000 per day per violation.
When the required corrective actions are complete, please notify this office in writing at the above
address. If you have any questions concerning this matter, please call Andy Heminger, Brian Wrenn, or
Dave Holsinger at 910-395-3900.
Sincerely,
Andrew G. Hemnnger
Environmental Specialist
cc: Harold Jones, County Soil and Water Conservation
Sandra Weitzel, NC Division of Soil and Water Conservation
Operations Branch
Wilmington Files
S. 4WQSWVDYAl1 o-29.DEF

i
n`. Review:
:Feedlot Operafxon Site h
Routine O Cam laint O Follow-up of DWQ inspection O Follofv-up of DSWC review O Other
Date of Inspection 3 3 ?
Facility Number
Time of Inspection OQ Use 24 hr. time
Farm Status: .... Ce �� Total Time (in hours) Spent onRe«e`v
" �� " or Inspection (includes travel and processing) Z5
Farm Name: rrd,,>R clah.�_...� �`_ �__.� ... Cauntv:.. _ t i • -� :..
Owner Name:Phone No:[.rl.ZQ1- 7.- It
MailingAddress: 1 .. v4L
Onsite Representative: Au� Llab—, _ - _ , Integrator:.�I.tYY4
Certified Operator: b .3�..C.1�.taJaS Operator Certification Number:
Location of Farm:
MA
Latitude 314'® Longitude ®• 0� 3 7 °�
10 Not U erational
Date Last Operated:
. 1 ype of Operation and Design Capacity
Latitude 314'® Longitude ®• 0� 3 7 °�
10 Not U erational
Date Last Operated:
. 1 ype of Operation and Design Capacity
wl •:.
Number_.. poultry Number
Cattle Number
.:, ..... , b .
Wean to Feeder
❑Laver
: ❑ Dairy
❑ Feeder to Finish
_
❑Non -Laver
❑ Beef
:.ELFarroxv to WeanEl
.. -
Farrow to Feeder
El Farrow to Finish
� � ❑ Other Type of Livestock
x
�Nurnber of La uaas /kHoidtn Ponds ❑ Subsurface Drains Present
❑ ea Lagoon Ar❑Spray Field Area
010
General
1. Are there any buffers that need maintenance/improvement? ❑ Yes ja No
2. Is any discharge observed from any part of the operation? ❑ Yes [)J No
a_ If discharge is observed, was the conveyance man-made? ❑ Yes- W No
b. If discharge is observed, did it reach Surface Water? (If yes, notiry DWQ) ❑ Yes ® No - -
c. If discharge is observed, what is the estimated flow in gal/min? IVAA
d. Does discharge bypass a lagoon system? (If yes, notify DWQ) ❑ yes [M No
i. Is there evidence of past discharge from any part of the operation? i Yes Of No
�r4. Was there any adverse impacts to the waters of the State other than from a discharge? ❑ Yes W No
5. Does any part of the waste management system (other than lagoons/holding ponds) require $ Yes ❑ No
maintenance/improvement?
Continued on back

6. Is facility not in compliance with any applicable setback criteria?
7. Did the facility fail to have a certified operator in responsible charge (if inspection after 1/1/97)?
8. Are there lagoons or storage ponds on site which need to be properly closed?
Structures (Lagoons and/or Holdina Ponds)
9. Is structural freeboard less than adequate?
Freeboard (ft): Lagoon 1
10. Is seepage observed from any of the structures?
Lagoon 2 Lagoon 3
11. Is erosion, or any other threats to the integrity of any of the structures observed?
12. Do any of the structures need maintenance/improvement?
(If any of questions 9-12 was answered yes, and the situation poses an
immediatepublic health or environmental threat, notify DWQ)
13. Do any -of the structures lack adquate markers to identify start and stop pumping levels?
NVaste Application
14. Is there physical evidence of over application?
(If in excess of WMP, or runoff' entering waters of the State, notify DWQ)
15. Crop type
16. Do the active crops differ with those designated in the Animal Waste Management Plan?
17. Does the facility have a lack of adequate acreage for Iand application? -
18. Does the cover crop need improvement?
19. Is there a lack of available irrigation equipment?
For Certified Facilities Only
20. Does the facility fail to have a copy of the Animal Waste Management Plan readily available?
21. Does the facility fail to comply with the Animal. Waste Management Plan in any way?
22. Does record keeping need improvement?
23. Does facility require a follow-up visit by same agency?
24. Did Reviewer/Inspector fail to discuss review/mspection with owner or operator in charge?
❑ Yes
P No;
❑ Yes
cox�-O
❑ Yes
No
❑ Yes
No
Lagoon 4
❑ Yes JU No
❑ Yes 12 No
m Yes ❑ No
❑ Yes M No
❑ Yes ® No
❑ Yes 10 No
❑Yes ®No
❑ Yes [2 No
❑ Yes .In No
❑ Yes W No
Yes ❑ No
[A Yes ❑ No
CO Yes ❑ No
❑ Yes ® No
Comments �r`efer to question. Exglatn ariy YFS answers:andlor any recommendations or any'ather catnments
� � Nc -gym �, .,.., .. .Fn � .xi' '�t.,-..,::--:�� x� � � ,N'""" '.� ��ry.. A+^z+v,'� 8�._•m ___: x � � ¢� xs ° '�_ �_
Use drawm�s'�"°offacilttx to better explamsifztatrons� ttse additional:�ages: asM.�ecessarY).�.ga =� .tom �.�r�..� � _� �� :.z..
�.� malf West ivas f�-AseruedJ ll h v Co1ki 36 1d j r� 1k �;1c��e 4r, sp Yoe(-'tPl�!%�. J1Ju5 Lw Ici 4
O�C�VmvIO-�eL� lI� a i-re�� �4TGV� UM[Jif1SSP0 'T'V�Yi7UCiL � �✓i�t►'tG.�e �i�� 7� �Ks 1�5iUC
W Su�ScSec1 `�0 ��no oxa�Y �ntn� tvu { 1lDc Y�l� �tr' a`��liCCc�lar,, a,�
revel �'v�v� ►-� � �`� a1 -q } - {-
Q�iperr S i �On C Laxit- se rfms Mt 4 be- re C�(� �o ��M t'XOSio��o f � aTi0-
avmv�tie Flu ayea W�Ii IS roWlak r( C - ! a�a)t a�1 I r^ �`� 11►-ta
m-X �4o s �i rt.Ecd3 � e buy ,cc1. t �y���rn���y � r � �d � � s � wi, �cG► i5
e I os # i A� In sa � 7
�+ t W cw.a t. `itu fry s� be r -Plan.
no � , r� i�'l� [fW' ,,11,',b �!�) � �G 'l
ndf eve. 5pooy rpCordS Al a&,OL( ffig Q 7vu tfaS.
Reviewer/Inspector Name
Reviwer/Inspector Signature:
LDate
Wjj
cc: VivlSion of Water Quality, Water Lluality.]ection, FacilityRSSessment Unit 11/1.1196

State of North Carolina
Department of Environment,
Health and Natural Resources
James B, Hunt, Jr., Governor
Jonathan B. Howes; Secretary
November 13, 1996
Marvin Evans
Juniper Creek
6656 Mrytle Head Road
Ash NC 28420
SUBJECT: Operator In Charge Designation
Facility: Juniper Creek
Facility ID#: 10-29
Brunswick County
Dear Mr. Evans:
Senate Bill 1217, An Act to Implement Recommendations of the Blue Ribbon Study
Commission on Agricultural Waste, enacted by the 1996 North Carolina General Assembly,
requires a certified operator for each animal waste management system that serves 250 or more
swine by January 1, 1997. The owner of each animal waste management system must submit a
designation- form to the Technical Assistance and Certification Group which designates an
Operator in Charge and is countersigned by the certified operator. The enclosed form must be
submitted by January 1, 1997 for all facilities in operation as of that date. Failure to designate a
certified operator for your animal waste management system is a violation of 15A NCAC 2H
.0224 and may result in the assessment of a civil penalty.
If you have questions concerning operator training or examinations for certification, please
contact your local North Carolina Cooperative Extension Service agent or our office.
Examinations have been offered on an on -going basis in many counties throughout the state for
the past several months and will continue to be offered through December 31, 1996.
Thank you for your cooperation. If you have any questions concerning this requirement please
call Beth Buffington or Barry Huneycutt of our staff at 919/733-0026.
Sincerely,
�j
A. Preston Howard, Jr., P. ., rrector
Division of Water Quality
Enclosure
cc: ' Wilmington Regional Office
Water Quality Files
P.O. Box 27687, �y�C FAX [phone]
Raleigh, North Carolina 2761 1 7687 An Equal Opportunity/Affirmative Action Employer
Voice 919-715-4100 50% recycled/10% post -consumer paper

Y 0 —
V o c
rlj tL o
D
Q�Uc
•F o
Ei' � •a c m
r-q EL rc 4
s3 5 a
4) o o u
OGC� zoo
fM
SENDER:
+ Conplete items 1 andlor 2 for additional services.
• C6mplete items 3, and 4a & b•
m • Prini your name and address on the reverse of this form so that we can
f 7 return this card to you. rnailpieee, or on the back if spare
1D he
i does not permit.
Q . write "Return Receipt Requested'" an the mailpiece below the article he to
al how to whom the article was delivered and the date
i also wish to receive the
following services (for an extra we
fee):
�. ❑ Addressee's Address rn
G
2. ❑ Restricted Delivery m
t ++ . 7heReturnRecetptw� 5 ConsultOStmaster for fee. cc
C delivered. 4a. Article Number >�
! Article Addressed to'. Z 441 972 612 m
Mr. Marniv Evans
6656 Myrtle Head Road
Ash, NC 28420
i U
5. 'Si tore lAd re ee)
. Signature (Agent)
cc
0
PS Form 3811, December 1991
4b. Service Type at
❑ Registered ❑ Insureds'
® Certified
❑ COD
❑Return Receipt for �
[I ExPrase Mail Merchandise I5
5dS/= Date of Delivery 0
0
8. Addressee's Address (Only if requested
9 and fee is paid) 0
*LUI5 GPO' ,�s3—ssz-714 DOMESTIC RETURN RECEIPT

V r
SUUE o-
State of North Carolina
Department of Environment,' Health, and Natural Resources
Wilmington Regional Office
James B. Hunt, Jr. Division of Environmental Management Jonathan B. Howes
Governor Water Quality Section Secretary
August 10, 1995
Certified Mail # Z 441 972 12
Return Receipt Requested
Mr. Marvin Evans
6656 Myrtle Head Road
Ash, North Carolina 28420
Subject: Juniper Creek Farm
Facility Number 10-29
County
•$(�V�1SWl�.IL
Dear Mr. Evans:
•
On July 18, 1995 staff from the Wilmington Regional Office of the Division of Environmental
Management inspected your animal operation and the lagoon serving this operation. It was observed that
your waste lagoon had insufficient freeboard.
NRCS guidelines for Best Management Practices require a minimum of one foot seven inches of
freeboard. This is based on the amount of storage space needed to contain a 25-year storm event of 24
hours duration. Your lagoon should be pumped down to meet the minimum freeboard requirement. The
wastewater spraying activity should be done in accordance with MRCS standards which will prevent runoff
from your spray field(s).
To remain a deemed permitted facility, all corrective actions must be made within seven (7) days.
Failure to do so may result in the facility losing it's deemed permitted status, requiring a certified waste
management plan and certification form for the facility to be submitted prior to the December 31, 1997
deadline, and being required to obtain an individual non discharge permit for the facility.
Please be aware it is a violation of North Carolina General Statutes to discharge wastewater to the
surface waters of the State without a permit. The Division of Environmental Management has the authority
to levy a civil penalty of not more than $10,000 per day per violation.
127 Cardinal Drive Extension, Wilmington, N.C. 28405-3845 • Telephone [phone] • Fax M-350-2004
An Equal opportunity Affirmative Action Employer

:
Marvin Evans
August 10, 1996
Page 2
When the required corrective actions are complete, please notify this office in writing at the address
below. I you have any questions concerning this matter, please call Steve West or Dave Adkins at
[phone].
Sincerely,
B. Steven West
Environmental Chemist
cc: Dave Adkins - Regional Water Quality Supervisor
Duplin County Soil and:Watei Conservation District
Duplin County Health Department
Tom Jones - NC Division of Soil and Water Conservation
Operations Branch
0
•
•

• JUNIPER CREEK FARM
6656 MYRTLE H9AD RD., NW
ASH, NO 28420
August 12, 1995
To: B. Steven west, Environmental Chemist
Dave Adkins, Regional Water Quality Supervisor,
FROM: Marvin L. Evan•, Owner
Juniper Creek Farm
RE: Certified letter received this day.
July 18, 1995, two men, identifying themselves as employees
of DEM, visited my farm for the stated reason to inspect
my waste lagoon and spray field. They spoke with my wife.
Upon inspection, she was told that things looked good, w6
needed to get with Harold Jones from Brunswick county Si�ils
and Conservation to get the forms to keep records of our",
waste disposal operation. she wag also told to spray eery
day that weather and moisture permitted. She was not giv6n
a written cosy or anything to keep in -our records to verify
• the inspection or the results. We say we,should have been
given this information at the time of inspection.
At no time during the inspection was anything about the lack
of "Free Board" mentioned.
My concern is, if things were found as stated in the letter,
why was nothing said that day to my wife or Harold Jones.
Also, I am concerned about the failure of those person doing
the inspection to record properly the location of my farm,
and to notify person(s) that could help me correct the stated
problems. I am that even though Harold Jonas
was present during the inspection, neither of the persons
doing the inspection took the time to tell him of the problems
found. If he had been told, the problem would be taken care
now,
I dv nbt iiv6 in Duplin County, own property in Duplin County,
work in Duplin, or know anyone in Duplin.
Considering the lack of correct information, I am requesting
that my farm be inspected again at an appointed time, and ---
a copy of the reporl.be given to either myself or my wife.
I do not think this request unreasonable, because if they
• did not know which county they were in, how can they be sure
whose farm was whose.
I can be reached at [phone] or [phone], When

you plan to r$visit my farm, please ca11 to assure that Borne-
. one is there to meet with you.
Directions to my farm from Wilmington are as follows:
Take US 17 south from Wilmington to the intersection
of NC 130 west at shallotte. At that stop light take
a right turn toward Whitevi Ile, go past the fire tower
to the first paved road on right. This will be Big
Neuk Rd., follow that road to a stop sign at a cross-
road, go straight across the intersection and you are
on Myrtle Head Rd.. Travel about four miles and on
the right is a church. Across from the church is a
gravel farm road with a Carroll's Foods sign beside
it. My farm is about 2600 feet up that road on the
right.
am sending along with this memo a copy of the letter
received today from you.
E 1�1 c� Yl L t A \A �`

t- t*
Axj ,*. *IAS= PLAN CSRTZ7XC==0N ?cR IIEt OR A2ID� ��z.C.TS
?:vase rat-4= tea crmplst=d fora to the Div3sian of MMv?—=^--t.al Xaaigem-nt at
t :e add=asa an the ravarao side of Ls.is foe.
Nameof farm (Please print)
AQQr e5S : ( T 1
Phone No 6110
Farm locations: Latitude and Longitude:.' �� ��� 3a �_� (required) . Also,
please attach a copy of a caunty road map with location identified.
Type of operation (swine.: layer. dairy, etc.) :_ 5 e e,F �
Design capacity (number of animals) :. 14Z ,T
Average size of operation (12 month population avg.); _1 `575- 3
Average acreage needed for land application of waste (ac_es)s
areas:sanessssasssssassssssasassssasaasasa:sssassasssass�assassasssassassasalss
I&C_h=iCxI $peCis3ist Certif3cat3oa
As a tecisnical.specialist designated by the North Carolina Soil •and Water
Conservation Co=i.ssion pursuant to I5A NCAC 6F .0005. I certify that the new or
expanded animal waste-manageA-at system as installed for the farce named above
has an animal waste, management plan that meets the design, construction,
operation and maintenance -standards and specifications of the Division of
Environmental Management and the USDA -Soil Conservation Service and,/or the North
Carolina Soil and Water Conservation Commission pursuant to ISA NCAC 2E:0217 and
ISA NCAC 6F .0001-.0005. The following elements and their corresponding minimum
c=iteria-haxe_beea_verified by me or other designated technical specialists and
are included in the plan as applicable: minimum separations (buffers) isers or
equivalent for lagoons or waste storage ponds;'waste storage -cipacity.-agequate
quantity and amcunt of land for waste utilization (or us�f third party); access
or ownership Jof. proper waste, application eq=pme_nt; schedule - for timing of
applications; application rates;. loading -rates; -aid. the cQntr'ol of -'the discharge
of pollutants: fi6m 'stoimwate.r runoff -events less severe 'thin the -25-year.:�2i-hour
storm. ~_._:.>,>.._�.,,,I __a ��.� _ - - -
Sams of Teehaical-S'poclalist -(Please Print) �� r�tS ��✓c� ��
Affiliation: GS
Address (Agency) : 12 2 wr tic c. Phone No. g/, - .7 5- -T - ­/4.
Signature: C-f� Date:
:aasasssasss�ssssassassssss� sassssssasasssassssasarssssssassasassssrss
CW=ftrIx=ager �Qreesn�L
I (we) understand the operation and maintenance procedures established in the
approved animal waste management plan for the farm named above and will implement
these procedures. I (we) )mcw that any additional expansion to the existing
design capacity'of the waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the Division of
Ewwironmental Management before the new animals are stocked. I (we) also
understand that there must be no discharge of animal waste from this syste= to
surface waters of the state either through a man-made conveyance or through
runoff from a*'siorsa -event less severe than the 25-year, 24-hour storm. The
approved. plasi'-iiill -be filed at the farm and at the office of -the local Soil and
Water Conservation District.._. `M r
Sam! of Land *%Mar -(Please Print) 1 , `asr tl s kA 1-=, i„_ . jj
Signature, _ y e-�l.uwJ m_�[1c.� = mat e ..-
game of Saazgar, if different from owner (Please print)i
Signature: - Date: ---
_4atg�._ •. A .change=f it->landi"cwrie=sIiiIP wires notification or a new •certi- ication
(if - --the _ apprcvea:--p`iaa pis -changed? to be submitted to the Division of
Emvironmental-Managemeatvith3a '60 days of a title transfer.
DFZi USE OHI.Y:AC1+0:W 6
/D-ZZ9 - -
ate+
ca
+�
Q :r
Q

'oday the county seat is at Bolivia. Rear River shore shows its flowering ton Pl.
Brunswick County's southern border is beauty from March through November.
-med by the Atlantic Ocean. The. Cape On the shores of the Cape Fear River
r River acts as the county's eastern and lies historic Brunswick Town. This col -
of the northern border, while the onial port town was begun in 172.6 as a
IAT.w.w_w._ n!___- .L_ ___.__11__ L T. :Le_ _
I®

REGISTRATION FORM FOR ANIMAL FEEDLOT OPE ONS ',".
Department of Environment, Health and Nat
`�Ftesoucvs
Division of Environmental Manageme
Water Quality Section Q
tiCP
If the animal waste management system for c
g Y Your feedlo�'�:¢g�.ratcin: Is
designed to serve more than or equal to 100 head 75
horses, 250 swine, 1,000 sheep, or 30,000 binds that are served by
a liquid waste system, then this form must be filled out and mailed
by December 31, 1993 pursuant to 15A NCAC 2H.0217(c) in order to be
deemed permitted by DEM. Please print clearly.
Farm Name 1►' lc3U`L��Y� E'Va(1)
Mailing Address: 66 S6 / y J (I
County :r)v\uy1 SSA+ (C IS'
Owner(s) Name: o1
Manager (s) Name: _ S`ac,-A .e
Lessee Name:
Latitude/Longitude if known:
C�
Design capacity of animal waste management system (Number and type
o- confined animai (s)) : �`vlCiaS�o �)O"secs) wi j:� waste-.2 V,t--sUpto
Average animal population on the -farm (Number and type of animal(s)
raised) O
Year Production Began: `q f3 ASCS Tract No.: c2,d6/— Z/ 7� �
Type of waste Management System Used: La o c"
Acres Available for Land Application of Waste: 3 0
Owner (s) Signature (s) : dAxj7/(.J. DATE: 12
/0 -,79

Stare of North Carolina
Department of Environment,
Heaith and Natural Resources
Division or LEnvironmental Nlanagement
Jcmes S. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
A. Preston Howard, Jr., P.E., Director
February 17, 1994
Marvin Evans
6656 Mrytle Head Road
Ash NC 28420
Dear Mr_ Evans:
This is to inform you that your completed registration form required by the recently
modified nondischarge rule has been received by the Division of Environmental. Management
(DEM), Water Quality Section.
On December 10, 1992 the Environmental Management Commission adopted a water
quality rule which governs animal waste management systems. The goal of the rule is for
animal operations to be managed such that animal waste is not discharged to surface waters
of the state. The rule. allows animal waste systems to be "deemed permitted" if certain
minimum criteria are met (15A NCAC 2H .0217). By submitting this registration you have
met one of the criteria for being deemed permitted.
We would like to remind you that existing feedlots which meet the size thresholds
listed in the rule, and any new or expanded feedlots constructed between February 1, 1993
and December 31, 1993 must submit a signed certification form (copy enclosed) to DEM by
December 31, 1997. New or expanded feedlots constructed after December 31, 1993 must
obtain signed certification before animals are stocked on the farm. Certification of an
approved animal waste management plan can be obtained after the Soil and Water
Conservation Commission adopts rules later this year.
We appreciate you providing us with this information. If you have any question about
the new nondischarge rule, please contact David Harding at [phone].
Sincerely,
Steve Tedder, Chief
enc: Water Quality Section
P.O. Box 29535, Rdeigh, North Carorina 27626-0635 Telephone [phone] • FAX [phone]
An Equai Opportunity Aftmatnre Action Employer 50% recycled/ 10% post -consumer paper

b
REGISTRATION FORM FOR ANIMAL FEEDLOT OPERATI03
Department of Environment, Health and Natural Res( rL(PA
Division of Environmental Management
Water Quality Section SRME
If the animal waste management system for your feedlot or �.
designed to serve more than or equal to 100 head of
horses, 250 swine, 1,000 sheep, or 30,000 birds that are �� aq
a liquid waste system, then this form must be filled out
by December 31, 1993 pursuant to 15A NCAC 2H.0217(c) in o
deemed permitted .by DEM. Please print clearly.
Mai^,/c`e)�V �1/1 5
Farm Name:
Mailing Address: 4P(0 Is
�Ria Fav,vyN
County: w i (f-1Y
Owner(s) Name: Ma."Poc' l (-, EV&rid.
Manager (s) Name: rii av- o a in.- L LL
Lessee Name: A11A
ZIP Z 6
Phone No. 9!dr
- S0 F i?
Farm Location (Be as specific as possible: road names, direction,
milepost, etc.) S R V .3 5 133 �c _4;t-
a b1 S
a j t A .. _ 4 - . ... . — - (Y I C - I-- — . V . . 1, _ i . rzo- — i , . !I—
�Qti u U
Latitude/Longitude if known:
Design capacity of animal waste management S stem (Number ar�d type
of confined animal( ) ,En�ldS }_ hC(A 5
Average animal population on the farm (Number and type of animals)
raised) : 3 O m 0 i ct S
Year Production Began: Ig93 ASCS Tract No.:_.. 621--'5LO-73
Type of waste Management System Used:
Acres Available for Land Application of Waste: �(1
Owner (s) Signature (s) : DATE: /l�5 —
DATE •

�c- Ncrh Ccroiira
Dencr�r;�ent of Environment,
Heci,7 cnd Nclurci Resources
Civisicn ofnvironmentci Nfcnc5cmenl'. 4:
Jcmes B. i-'unf, Jr., Governor
Jonc'hcn 8. Hcwes, Secretcry ---
A. Pres�cn Howcrd, Jr., P.E., Director
January 21, 1994
Marvin L. Evans
6656 Myrtle Head Rd.
Ash NC 28420
Dear Mr. Evans. -
This is to inform you that your completed registration form required by. the recently
modified nondischarge rule has been received by the Division of Environmental Management
(DEM), Water Quality Section.
On December 10, 1992 the Environmental Management Commission adopted a water
quality rule which governs animal waste management systems. The goal of the rule is for
animal operations to be managed such that animal waste is not discharged to surface waters
of the state. The rule allows animal waste systems to be "deemed permitted" if certain
minimum criteria are met (15A NCAC 2H .0217). By submitting this registration you have
met one of the criteria for being deemed permitted.
We would like to remind you that- existing feedlots which meet the size thresholds
listed in the rule, and any new or expanded feedlots constructed between February 1, 1993
and December 31, 1993 must submit a signed certification form to DEM by December 31,
1997. New or expanded feedlots constructed after December 31, 1993 must obtain signed
certification before animals are stocked on the farm. Certification of an approved animal
waste management plan can be obtained after the Soil and Water Conservation Commission
adopts rules later this year.
We appreciate you providing us with this information. If you have any question about
the new n6ndischarge rule, please contact David Harding at [phone].
Sincerely,
/� Steve Tedder, Chief
Water Quality Section
P.O. Sox 29535, Rdeigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Empicyer 50% recycled/ 10% post -consumer paper