310861_HISTORICAL_20171231

NORTH CAROLINA
Department of Environmental W6

ggl
ME
R= vC .if.1'UWA5...
NITROGEN ONLY &ANIMAL WASTE ONLY PLAN
PRODUCER: Dark Branch Nursery -- Mary Jernigan
LOCATION: Hwy 11; Kenansville, NC - Duplin County
TELEPHONE: . [phone]
TYPE OPERATION: Wean to Feeder
Anaerobic lagoon
NUMBER OF ANIMALS: 2,600
(Design Capacity)
The waste from your animal facility must be land applied at a specified rate to prevent pollution of
surface and/or groundwater. The plant nutrients in the animal waste should be used to reduce the
amount of commercial fertilizer required for the crops in the fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed before
each application cycle. Annual soil tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize the
fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner. Always
apply waste based on the needs of the crop to be grown and the nutrient content of the waste. Do not
apply more nitrogen than the crop can utilize. . Soil types are important as they have different
Infiltration rates, leaching potentials, cation exchange capacities, and available water holding
capacities. Normally waste shall not be applied to land eroding at greater than 5 tons per acre per
year. With special precautions, waste may be applied to land eroding at. up to 10 tons per year. Do
not apply waste on saturated soils, when it is raining, or when the surface is frozen. Either of these
conditions may result in runoff to surface waters which is not allowed under NCDENR regulations.
Wind conditions should also be considered to avoid drift and downwind odor problems. To maximize
the value of nutrients for crop production and to reduce the potential for pollution, the waste should be
applied to a growing crop or applied not more than 30 days prior to planting a crop or forages breaking
dormancy. Injecting the waste or disking will conserve nutrients and reduce odor problems.
This plan is based on the waste application method shown above. if you choose to change methods in
the future, you need to revise your plan. Nutrient levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on typical nutrient content for this
type of facility. In some cases you may want to have plant analysis made, which could allow additional ;
waste to be applied. Provisions shall be made for the area receiving waste to be flexible so as to
accommodate changing waste analysis content and crop type. Lime must be applied to maintain pH in
the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC 2H.
0217 adopted by the Environmental Management Commission.
Page 1

Amount of Waft Produced Per Year (aallons. ft. tons. etc.)
2,600 animals Mill (gal) wastelardmal per year- 498,600 (gal) wastelyear
wean to feeder
Amount of PlantAvailable Nitrogen (PAN) Produced Per Year
498,600 gallons x 1.6 nb.s PAN11000 gallons irrigated or broadcast 894 4m, pAwyear. (PAN from N.C. Teat
Guide Std. 633)
Amount of PAN produced: 894 dlyr
Amount of PAN applied.1,697.04
Surplus/Deficit PAN: (-703.94)
Applying the above amount of waste Is a big job. You should plan time and have appropriate equipment to apply the waste In a timely manner.
The following acreage will be needed for waste application based on the crop to be grown and surface application:
Table is ACRES OWNED BY PRODUCER
Tract Field Sall Crop Lbs. N Acres Lba. N Month of
a! Ills lion ParAe-ra11111iyad Annlir-aflan
T4189
"A
MOC
Bermuda (no
221
3.880
553.06
illar I -Sept 30
T4189
Pug B
AUB
Bermuda reze
202
2.190
442.38
Mar 1-Se t 30
0
T4189
AWE A
McC
Small graln
50
3.860
193
Oct I -Mar 31
T4189
Puff B
AuB
Small aralnigWC
60
2.190
109.5
Oct 1-Mar 31
0
yaw I a.asl 7,atrr.Ve I
Vdume applied (94 887,745.00
Volume produced (gal) , 496,BW.00
SurphWileflell (gal) ' (391,145.00)
'This Nis from snimal waste only. if nutrients from oihersources such as commercial ferillizer are appffed they must be accounted Mn N musi be
based on rae1110'c vlald expectation. -
NOTE The applicator is cautioned that P and K may be over applied while meethrg Um N requin m ahL 09gInning in 1996 the Coastal Yane
Management Act w8f rsgubv farmers In some easfsm counfles of North Carofhia to have a nu&Mnt management plan that addresses ap nuirlants.
This plan only addresses NltrogwL
If waste Is to be sag Incorporated or infected. PAN will be 2-16 Ibs PAN11,000 gallons:
498,600 gallons x 2.16 [be PAE111,000 gal soil inoorp or Injected = 1.073 Ors PAN/year
which would remit in a deficit also.
If bermude on Pug A Is grazed, use 165.751ba PANfac x 3.88 ac = 639.7 The PAN utigzed on Pull A barmuda If grazed
If bermude on Pug B Is hayed, use 252.5lbs PANIae x 2.19 ac= 652.97 lbs PAN utilized on Pull B bermude If hayed
If both pulls are grazed, this win remit in a deficit also (1,384.5a tbs PAN total u0lized If bath puffs are grazed) = (4190.58)
Page 2

NARRATIVE
Realistic yield expectatia
RYE
soil series
Pull B
RYE
soil series
jda 4.8 t/ac
MCC
Bermuda
5.5 t/ac
AuB
grain i t/ac
MCC
small grain
1 t/ac
AuB
This WUP Is a revision of the previous plan prepared by Murphy -Brown. Acres &
soil types used are according to previous plan and maps from Duplin Sol] & Water.
Pulls used in,this plan were developed by Duplin Soil & Water using on -site Information.
Summary of crops that can receive effluent during each month:
January:
Smaii grain
February:
Small grain
March:
Small grain
Bermuda
April:
Bermuda
May:
Bermuda
June:
Bermuda
July:
Bermuda
August:
Bermuda
September:
Bermuda
October:
Small grain
November:
Small grain
December:
Small grain
Estimated Sludge Accumulation:
6.7 gallons of sludge/pig/year x 2,600 animals = 17.420 gallons sludge produced/year
Approximately 10.2 Ibs PAN/1,000 gallons sludge (broadcast or irrigate)
Approximately 12.24 Ibs PAN11,000 gallons sludge (soil incorporated or injected)
At 17,420 gal sludgetyr and 12.24 ibs PAN/1,000 gal sludge = 213.3 Ibs PAN in sludgetyear
If applied to com at 150 Ibs PAN/ac need about 1.5 acres of land for application.
"Refer to current state general permit for guidelines "
Data to write this plan was taken from http:!lnutrients.so]I.ncsu.edu/ which meets current
NRCS standards (590)

y '-fs j) i}S,i��] a x� MAX
NMI
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2 There must be documentation In the design folder that the producer either owns or has an
agreement'for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to property dispose of waste, he/she shall provide a copy of an
agreement with.a landowner who is within a reasonable proximity, allowing him/her the use of
the land for waste application. It is the responsibility of the owner of the facility to secure an
update of the Waste Utilization Plan when there is a change in the operation, increase in the
number of animals, method of application, receiving crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based on soil type, available- moisture, historical data, climatic conditions, and level of
management, unless there are regulations that restrict the rate of application for other
nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste may
be applied to land that is eroding at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves the field. (See FOTG Standard
393 - Filter Strip).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste should
not be applied when there is danger of drift from the irrigation field.
B When animal waste is to be applied on acres subject to flooding, it will be soil incorporateq on
conventionally tilled cropland. When applied to conservation tilled crops or grassland, the
waste may be broadcast provided the application does not occur during a season prone to
flooding_ (See "Weather and Climate in North Carolina" for guidance.)
7 Liquid waste shall be applied at rates not to exceed the soii infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift from the
site during application. No ponding should occur in order to control odor or flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the surface
is frozen.
Page 5

'�c- 3 rh5 aj.• , s w'�- - �nr 'r � `'� t �.. S .4c � i je'w'�
H- ...'
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is not
covered with waste to a depth that would inhibit growth. The potential for salt damage from
animal waste should also be considered.
10 Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a
high potential for leaching. Waste nutrient loading rates on these soils shoufd be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste shall
not be applied more than 30 days prior to planting of the crop or forages breaking dormancy.
Any new swine facility sited on or after October 1, 1995 shall comply with the following: The
11 outer perimeter of the land area onto which waste is applied from a lagoon that is a component
of.a swine farm shall be at least 50 feet from any residential property boundary and canal.
Animal waste other than swine waste from facilities sited on or after October 1, 1995, shall not
be applied closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips).
Animal waste shall not be applied closer than 100 feet to wells.
12
Animal waste shall not be applied closer than 200 feet of dwellings other than those owned by
13 the landowner.
Waste shall be applied_ in a manner not to reach other property and public right-of-ways.
14
Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
15 discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided they have been approved as a land application site by a "technical specialist".
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that causes no runoff or drift from the site.
Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall not
1$ be discharged into the animal waste management system.
Page 6

REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas (lagoon
embankments, berms, pipe runs, etc.). Areas shall be fenced as necessary to protect the
vegetation. Vegetation such as trees, shrubs, and. other woody species, etc., are limited to
areas where considered appropriate. lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence of erosion, leakage or
discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is responsible
for'obtaining and implementing a "closure plan' which will eliminate the possibility of an illegal
discharge, pollution and erosion.
19 ' Waste handling structures, piping pumps, reels, etc., should be inspected on a regular basis to
prevent breakdowns, leaks and spills. A regular maintenance checklist should be kept on site,
Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumptlon. However, if animal waste is used on crops for direct human
20 consumption it should only be applied pre -plant with no further applications of animal waste
during the crop season.
Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
21 managed to maintain the liquid level between the markers. A marker will be required to mark
the maximum storage volume for waste storage ponds.
Waste shall be tested within 60 days of utilization and soil shall be tested at least once every
three years at crop sites where waste products are applied. Nitrogen shall be the rate -
determining nutrient. unless other restrictions require waste to be applied based on other
22 nutrients, resulting in a lower application rate than a nitrogen based rate. Zinc and copper
levels in the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted for optimum crop production and maintained.
Records shall be kept for at least three (3) years for state general permits. Poultry dry waste
application records shall be maintained for three (3) years. Records shall be kept for at least
fire (6) years for NPDES permits. Waste application records for all other waste shall be
maintained for five (5) years.
23
Dead animals will be disposed of in a manner that meets North Carolina regulations.
Page 7

WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: Dark Branch Nursery
Owner/ ManagerAgreement
I (we) understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste utilization plan for the farm
named above. i (we) know that any expansion to the existing design capacity of the waste
treatment and storage system or construction of new facilities will require a new certification to
be submitted to the Division of Environment Management (OEM) before the new animals are
stocked. I -(we) also understand that there must be no discharge of animal waste from this
system to surface waters of the state from a storm event less severe than the 26-year, 24-hour
storm. The approved plan will be tiled on -site at the farm office and at the office of the local
Soil and Water Conservation District and will be available,for review by DEM upon request.
Name of Facility Owner: Mary Jernigan -
(F%ase Ammo
Signature:
Name of Manager (If different from owner):
l
Date:
Signature: - -- Date:
Name of Technical Specialist: (Meese pant) Amanda Hatcher
Affiliation: NCCES-Duplin County Center
Address (Agency): PO Box 949
Kenansville, NC 26349
( 10) 296-2143 ..�
Signature:Of,1/V�CI�I _ Date:
Page 8

ter, -�-:.� rF� �n t - ``C fs ` o � r -•' _ � aro
.��ti �• t� r' ,• sr8iat�.-y �- - r ,,��` r � -' .Yt` Sr
fmay`.•
\K>`"t c-^_ i`•J- <� _ r R,,�r ; zr:.. r'L—- •,..a ,ems:••S.-hi s��
�`�,.,, ..{�/�i�+,.�,,,,�� mow• � "fT � - . '�,� rY`� `.• , - �<F
- - . C }- - �""" 1. ! �' RfiiP �t.al_•^ b'. ,'r. 9" "'•' °"r �

(Multiple worksheets may be needed)
Hard Hose Traveling Gun System
C®MPUTA110 AL WORKSHEET
HARD HOSE TRAVELER
iRRiGATION SYSTEM
I. Farm number (identification) Field number (identification)
2. Irrigation system designatlon :✓'' Existing irrigation system New/expanded irrigation system
3. Number of travel lanes # Interior lanes - r l # Exterior lanes �? ir+ feet) Length of pull(Ll)
# Interior lanes .__ # Exterior lanes (feet] Length of pull(U)
# Interior lanes # Exterior lanes [feet] Length of pull(L3)
4. Wetted diameter Z 1) [feet] from Field Data Worksheet
5. Spacing Hydrant spacing [feet] '}-) T? [as a percentage of wetted diameter]
6. Hydrant layout Multiple hydrants Single hydrant - ' Excessively spaced hydrants
7. Read the irrigated area per travel pull for the given wetted diameter from the appropriate table and column
based on pattern, spacing, and.travel lane location.
Trravel lane length (L) Interior or A Exterior (lane/hydrant)
Q d (a) Acres start end of pull from Table f2 ` .': Column
) !r (b) Acres middle portion of pull (Ll)
l {Pull lengthZ [feet] X Wetted widtQU�, [feet]) / 43,560
0. Y) (c) Acres stop end of pull from Table 0 F 9 V Column C
f. Total acres for travel lane,length (L1) (Sum: a + b + c)
Travel lane.length (L) Interior or 6 Exterior oane/hydrant}
L+(, t (a). Acres start end of pull from Table �r Column �3
-(b) Acres middle portion of pull (1.2)
{Pull lengtha&jr [feet] X Wetted widthL4—D [feet]} / 43,560
(c) Acres stop end of pull from Table . II Column �
Total acres for travel lane length (12) (Sum: a + b + c)
Travel lane length (IL Interior or Exterior (lane/hydrant)
(a) Acres start end of pull from Table Column
(b) Acres middle portion of pull (L3)
{pull length [feet] X Wetted width [feet]) / 43,560
(c) Acres stop end of pull from Table Column
Total acres for travel lane length ") (Sum: a - + b + c)
8. Multiply the tabulated irrigated acreage value per travel pull by the number of pulls of each
category in the field. Add all of these, and this is the total irrigated acreage for the field.
(a) Acres per travel lane length (Li)
X
# Lanes
Acres
(b) Acres per travel lane length (L2)
X
# Lanes =
Acres
(c) Acres per travel lane length (L3)
X
# Lanes =
Acres
Total CAWMP wettable acres for Held (Sum: 8a + 8b + 8c)
Wettable Acre Computational Worksheet Completed by: Date:
Slgnatwre of technical specialist
5s

u.
3 ] .
qj Y;y.
Di
+^,: n�•�'-„�. X' .. . . � M1 x., xa •rM1• _ i Tl S L�' � � r'•r a �f,.z�;n - ,r ,� ,� � ��s
,
Ems, �.- _ .. :: L , yt � y ', � �r p a ) � � ,t� ':�•-.. .. � � 'r"� ^,
�"�.' ., { ]4-� f'�315 rfi +r �" a. S r y s,, -a 'r• - �iy:
' -' `r�'_•ti. - - - �- t,� 3 Y wig < � r � k _r t y _ V. yS--,m1 r i tJs
wtis..._�,; t'' V,+l � a i i-1-' 1 S '. t:- M1 .rK�' , � r •�'
3; 7.7•�t"�urr :,c - 'S xr?+ e. y Y -

.V,
'3/-"4i�U/
Producer: la k L�r�r. c (,-, /1%�,,•� e k— y — -- M c v­ � a. s t
Location: Ht,��J .11 . 1���.-.s v , +1 e A�C L�w� V. --N a .
Telephone:� �
Type Operation: , 3c- a r�ECEIVE©/ DENR
Aquifer PrdecGon Simon
Number of Animals: APR 4 ,1 4%
(Design sty) , A 7L
The waste from your animal facility must be land applied at a specified rate to pre�Z'
pollution of surface and/or groundwater. The plant nutrients in the animal waste ld
be used to reduce the amount of commercial fertilizer required for the crops in the fields
where the waste is to be applied. This waste utilization plan uses nitrogen as the limiting
nutrient. Waste should be analvzed before each application cycle. Annual soil tests are
strongly encouraged so that all plant nutrients can be balanced for realistic yields of the
crop to be grown.
Several factors are important in implementing your waste utilization plan in order to
maximise the fertilizer value of the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply more nitrogen than the crop.,
can utilize. Soil types are important as they have different infiltration rates, leaching
potentials, cation exchange capacities, and available water holding capacities. Normally
waste shall not be applied to land eroding at greater than 5 tons per acre per year. With
special precautions, waste may be applied to land eroding at up to 10 tons per acre per
year. Do not apply waste on saturated soils, when it is raining, or when the surface is
frozen. Either of these conditions may result in runoff'=to surface waters which is not
allowed under DEM regulations. Wind conditions should also be considered to avoid drift
and downwind odor problems. To maximize the value of nutrients for crop production
and to reduce the potential for pollution, the waste should be applied to a growing crop or
applied to bare ground not more than 30 days prior to planting_ Injecting the waste or
dkking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. Acreage requirements should be based on the waste analysis
report from your waste management facility. Attached you will find information on
proper sampling techniques, preparation, and transfer of waste samples to the lab for
analysis. '
This waste utilization plan, if carried out, meets the requirements for compliance with 15A
NCAC 21-0217 adopted by the Environmental Management Commission.

Amount of Waste Produced Per Year(allons._ftj, toms, etc.)
bOD animals X .`I_ waste/animallyear = I O`la (4fff—) waste/year.
Amount of Plant Available Nitrogen (PAN) Produced Per Year
.16g2 animals X Abs. PAN/animal/year =icy S lbs. PAN/year. (PAN from N. C. Tech.
Guide Std. 633)
i
,,:. f. , Y
Acre,
Applying the above amount of waste is a big job. You should plan time and have
appropriate equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on the crop to be grown
and surface application:
Table 1: ACRES OWNED BY PRODUCER
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
m No. Tvoe Per Ac. * Utilized Annlication
�N
- --
Total I E • C) ,I 301;l 5 1
* This N is from animal waste only. If nutrients from other sources such as commercial
fertilizer are applies!, they must be accounted for. N must be based on realistic yield
expectation_
NOTE: The applicator is cautioned that P and K maybe over applied while meeting the N
requirements, Beginning in 1996 the Coastal Zone Management Ad will require farmers in
some eastern counties ofNorth Carolina to have a nutrient management plan that addresses
all nutrients This plan only addresses Nitrogen.
2

Table ?: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowner must be attached)
(Required only if operator does not own
adequate land [see Rewired Specification 2])
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
* See footnote for Table 1.
Totals from above Tables
Acres Lbs. N
Utilized
Table 1 r. 0 3 0 5
Table 2
Total 1 . D 3O a G
Amount of oduced t
Surplus o eficit--1-17-7
NOTE: The Waste Utilization Plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient rich and will
require precautionary measures to prevent over application of nutrients or -other
elements ,
3

See attached map showing the fields to be used for the utilization of waste water.
Application of Waste by Irrigation
Field Sail Type Crop Application Application
No. Rate WIR Amount an
= TAME IS NOT MEMED IF WASH IS NOT BEING APnMD BY IRRIGATION, HOWEVER A SIIV C 4R TABLE WILL
BE NEEDED FOR DRY ITrrER OR SLURRY.
Your facility is designed forj$Qdays of temporary storage and the temporary storage
must be removed on the average of once every C2 MONTHS. In no instance should
the volume of waste being stored in your structure exceed Elevation ,Ksce I r, Aeg ,r�
Call the local Natural Resources Conservation Service (formerly Soil Conservation
Service) or Soil and Water Conservation District office after you receive the waste
analysis report for assistance m determining the amount per acre to apply and the proper
application rate prior to applying the waste.
4

REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff drift, manmade
conveyances, direct application, or direct discharge during operation or land
application. Any discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the producer either owns or has
an agreement for use of adequate land on which to properly apply the waste. If the
producer does not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a reasonable
proximity, allowing him/her the use of the land for waste application. it is the
resp onsibility of the owner of the facility to secure an update of the Waste Utilization
Plan when there is a change in the operation, increase in the number of animals,
method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic
crop yields based on soil type, available moisture, historical Baia, climatic conditions,
and level of management, unless there are regulations that restrict the rate of
application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre per year.
Waste may be applied to land that is eroding at 5 or more tons, but'less than 10 tons
per acre per year providing grass filter strips are installed where runoff leaves the field
(See FOTG Standard 393 - Filter Strip).
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil
incorporated on conventionally tilled cropland_ When applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not
occur during a season prone to flooding. (See "Weather and Climate in North
Carolina" for guidance.)
7_ Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
runoff does not occur offsite or to surface waters and in a method which does not
cause drift from the site during application. No ponding should occur in order to
control odor or flies.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.

.,
REQUIRED SPECIFICATIONS
(continued)
9. Animal waste shall be applied on actively growing crops in such a manner that the
crop is not covered with waste to a depth that would inhibit growth. The potential for
salt damage from animal waste should also be considered.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on sons
with a high potential for leaching. Waste nutrient loading rates on these soils should
be held to a minimum, and a suitable winter cover crop planted to take up released
nutrients. Waste shall not be applied more than 30 days prior to planting of the crop
or forages breaking dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the
following: The outer perimeter of the land area onto which waste is applied from a
lagoon that is a component of a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other than an irrigation
ditch or canal Animal waste other than swine waste from facilities sited on or after
October 1, 1995), shall not be applied closer than 25 feet to perennial waters. (See
Standard 393 - Filter Strips). .
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and public right-of-
ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands
by a discharge or by aver -spraying. Animal waste may be applied to prior converted
wetlands provided they have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc.,
• shall not be discharged into the animal waste management system.
l�

REQUIRED SPECIFICATIONS
(continued)
18. if animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks, and spills. A regular maintenance checklist should
be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops for
direct human consumption. However, if animal waste is used on crops for direct
human consumption it should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall
be managed to maintain the liquid level between the markers. A marker will be
required to mark the maximum storage volume for waste storage ponds.
22. Waste shall be tested within 69 days of utilization and soil shall be tested at least
annually at crop sites where waste products are applied Nitrogen shall be the rate- ,
determining elemeni. Zinc and copper levels in the soils shall be monitored and
alternative crop sites shall be used when these metals approach excessive levels. pH
shall be adjusted for optimum crop production and maintained- Soil and waste
analysis records shall be kept for five years. Poultry dry waste application records
shall be maintained for three (3) years. Waste application records for all other waste
shall be maintained for five (5) years.
23. Dead animals will be disposed of m a manner that meets North Carolina regulations.

AT3'°uNi,P::
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: f*_ B""a,
O►vner/Manager Agreement
I (we) understand and will follow and implement the specification and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. I (we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new facilities will require a new
certification to be submitted to the Division of Environment Management (DEM) before
the new animals are stocked I (we) also understand that there must be no discharge of
animal waste from this system to surface wasters of the state from a storm event less
severe than the 25-year, 24-hour storm The approved plan will be filed on -site at the
farm office and at the office of the local Soil and Water Conservation District and will be
available for review by DEM upon request.
Name of Facility Owner: M o. - a 5
(Please print)
Signature: Date: erL Z,
Name of Manager(If different from owner):
Signature:
Date:
Name of Technical Specialist. (Please print) �ra • W c 5 �e
Affiliation:_A ,%(--j�AI
Address (Agency)
Sign
acn>z -_� 5 `7
�oSe- �j 11(, lac- a_FLt 5 6-
I

)i,'
+r„
w
o�0� VA r�9QG
4 15� `C
Mary Jernigan Hasty
Dark Hill Farm
219 Clifford Lane
Kenansville NC 28349
Michael F. Easley, Govemor
William G. Ross Jr-, Secretary
North Carolina Department of Environment and Natura! Resources
May 1, 2003
Alan W. Klimek, P. E., Director
Division of Water Quality
Subject: Certificate of Coverage No. AWS310861
Dark Hill Farm
Swine Waste Collection, Treatment,
Storage and Application System
Duplin County
Dear Mary Jernigan Hasty:
On April 28, 2003, -the North Carolina General Assembly ratified Senate Bill 733 which directs the
— -Division -of Water -Quality (Division) to extend the expiration date of the Swine Waste Operation General- - - — -- -
Permit AWG100000. Therefore, the General Permit has been re -issued by the Division to extend the
expiration date to October 1, 2004. During the period of this extension the Division will be working with
all interested parties on the development of a new version of the Non -Discharge General Permit.
In accordance with your application received on March 25, 2003 and in accordance with the directive of
Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to Mary
Jernigan Hasty, authorizing the operation of the subject animal waste collection, treatment, storage and
land application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AWS310861 which expired on April 307 2003.
This approval shall consist of the operation of this system including, but not limited to, the management
_-----of.animal.waste.from.the.Dark Hill.Farm, located in.Duplin County, with an animal.capacity..of_no greater—,
than an annual average of 2600 Wean to Feeder swine and the application to land as specified in the
facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or Farrow to
Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary, they may
be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a rate of 4
gilts for every 3 sows
The COC shall be effective from the date of issuance until October 1, 2004. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.,
N[.'t7ENER
Non -Discharge Permitting Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
Customer Service Center
An Equal Opportunity Action Employer
Internet httpJ/h2o.enr.state.nc.us/ndpu
Telephone [phone] Fax [phone]
Telephone [phone]
50% recycled/110% post -consumer paper

Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per NRCS standards a 100 foot separation shall be maintained between water supply wells and any
lagoon or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Wilmington Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information -concerning
this COC or the General Permit, please contact Michelle Barnett at [phone] ext. 544.
Sincerely,
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
Wilmington Regional Office, Water Quality Section
Duplin County Health Department
DupIin County Soil and Water Conservation District
Permit File AWS310861
NDPU Files

c--
1 '
WASTE. UTILIZATION- PLAN
PRODUCER: Dark Branch Nursery -- Mary Jernigan
LOCATION: Hwy 11; Kenansville, NC -- Duplin County
TELEPHONE: (910) 296 - 0098
TYPE OPERATION: Wean -- Feeder
NUMBER OF ANIMALS: 2600
(Design Capacity)
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface and/or groundwater. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops in the fields where the waste is
to be applied. This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle. Annual soil tests are strongly encouraged so that all
plant nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and available water holding capacities. Normally waste shall not be applied to land
eroding at greater than 5 tons per acre per year. With special precautions, waste may be
applied to land eroding at up to 10 tons per year. Do not apply waste on saturated soils, when it
is raining, or when the surface is frozen. Either of these conditions may result in runoff to
surface waters which is not allowed under DEM regulations. Wind conditions should also be
considered to avoid drift and downwind odor problems. To maximize the value of nutrients for
crop production and to reduce the potential for pollution, the waste should be applied to a
growing crop or applied to bare ground not more than 30 days prior to planting. Injecting the
waste or disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage -requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for analysis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H.0217 adopted by the Environmental Management Commission.
Page 1

kv
s
WA$TE UTILIZATION PLAN
Amount of.Waste Produced.8er Year wallons, ft, tong. etc.)
2,600 animals X DA2 (tons) waste/animal/year = 1,092 (tons) waste/year.
3
Amount of Plant Available Nitrogen (PAN) Produced Per Year
2,600 animals X 0,0 lbs. PAN/animal/year = 1,248 lbs. PAN/year. (PAN frorn N.C.
Guide Std. 633) _. Tech
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner
The following acreage will be needed for waste application based on the crop to be grown and
surface application:
Table 1: - ACRES OWNED BY PRODUCER
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
# No. Tyne Per Acre Utilized Application
`This N is from animal waste only. If nutrients from other sources such as commercial fertilizer are
applied, they must be accounted for. N must be -based ou. realistic Yield expectation,
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N
requirements. Beginning in 1996 the Coastal Zone Management Act will require farmers in some
eastern counties of North Caroline to have a nutrient management plan that addresses all nutrients.
This plan only addresses Nitrogen.
q,
Page 2

i
WASTE UTILIZATION PLAN
Table 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowner must be attached)
(Required only if operator does not own adequate land (see
Required Specification 2))
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
# 110. Type Per Acre* Vilized Application
' See footnote for Table 1.
Totals from above Tables
Acres Lbs. N
Utilized
Table 1 12.81 3,010
Table 2
Total 12.81 3,010
Amount of N Produced 1,248
Surplus or Deficit (1,762
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to prevent over
application of nutrient or other elements.
Page 3

WASTE UTILIZATION PLAN
See attached map showing the fields to be used for the utilization of waste water.
Application of Waste by Irrigation
Field Soil Type
No.
Crop Application Application
Rate flnlHrl Amount fln_1
THIS TABLE IS NOT NEEDED IF WASTE IS NOT BEING APPLIED BY IRRIGATION, HOWEVER A SIMILAR TABLE
WILL BE NEEDED FOR DRY LITTER OR SLURRY.
Your facility is designed for M days of temporary storage and the temporary storage must
be removed on the average of once every $ MONTHS. In no instance should the volume of
waste being stored in your structure exceed Elevation *, ewe lagoon design.
Call the local Natural Resources Conservation Service (formerly Soil Conservation Service) or Soil
and Water Conservation District office after you receive the waste analysis report for assistance in
determining the amount per acre to apply and the proper application rate prior to applying the
waste.
Narrative of operation: Grower may overseed any of the Bermuda in field #2, as long as the rates
and timing shown are followed. Acres shown are "effective" acres.
Page 4

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of waste. he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner of the facility to
secure an update of the Waste Utilization Plan when there is a change in the operation.
increase in the number of animals, method of utilization, or available land.
Animal waste shall be applied to meet, but not exceed. the nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climatic conditions, and level
of management, unless there are regulations that restrict the rate of application for other
nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons. but less than 10 tons per acre per
year providing grass biter strips are installed where runoff leaves the field. (See FOTG
Standard 393 - Filter Strip).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6 When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland,
the waste may be broadcast provided the application does not occur during a season
prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor or flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
Page 5

- WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a
high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients_ Waste
shall not be applied more than 30 days prior to planting of the crop or forages breaking
dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm"shall be at least 50 feet from any residential property boundary
and from any perennial stream or river (other than an irrigation ditch or canal. Animal
waste other than swine waste from facilities sited on or after October 1, 1995), shall not be r
applied closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips).
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site by a "technical specialist'.
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that courses no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
Page 6

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
18 Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
19 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied propellant with no further applications animal waste
during the crop season.
20 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
21 Waste shall be tested within 69 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste analysis records shall be kept
for five years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
22 Dead animals will be disposed of in a manner that meets North Carolina regulations.
Page 7

WASTE UTILIZATION PLAN
Name of Farm: Dark Branch Nu
Owner / Manager Agreement
I (we) understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. I (we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new facilities will require a new
certification to be submitted to the Division of Environment Management (DEM) before the
new animals are stocked_ I (we) also understand that there must be no discharge of
animal waste from this system to surface waters of the state from a storm event less
severe than the 25-year, 24-hour storm. The approved plan will be filed on -site at the farm
office and at the office of the local Soil and Water Conservation District and will be
available for review by DEM upon request.
Name of Facility Owner: Mary Jernigan
(Please print)
Signature: Date: Z�--�9'
Name of Manager (if different from owner):
Signature:
Date:
Name of Technical Specialist: (Please print) Kraig A. Westerbeek
Affiliation: Murphy Family Farms
Address (Agency). -
Signature:
P.O. Box 759
Page 8

I ­�, I- loaj. I 1 -1 1 . �
I•L' A '-It
4L
V V4 0, j
fl
'I J w 1, di
Ij "0
6 t 'lei
:Vf;
FF-
Leo
It
y
P-W
F­
I.
I
a
Le
11

!AIM ;7' t
J
'ji A Roo
WA
WA
AN,
vi r.
to
71—
OIL-
i
4, Alt
'. IIIIIIIII

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Mary Jernigan Hasty
Dark Hill Farm
1027 N NC 11 903 Highway
Kenansville NC 28349
Dear Mary Jernigan Hasty:
i • •
1/ { yam- T
LFE!B 0 3 20CDEHR
N H CAROLINA DEPARTMENT OF
OE
MENT AND NATURAL RESOURCES
January 24, 2000
Subject: Conditional Approval
Animal Waste Management System
Facility Number 31-861
Duplin County
Our records indicate that your facility was conditionally certified in order to fulfill the requirements
of completion of your Certified Animal Waste Management Plan Certification. This letter is to inform you
of your unresolved conditional approval status. Any facility receiving a conditional approval must notify
Division of Water Quality (DWQ) in writing within 15 days after the date that the work needed to resolve the
conditional certification has been completed. Any failure to notify DWQ as required, subjects the owner to
an enforcement action. As of December 6, 1999, we have no record of any information from you, advising
us of the status of your conditional approval. Therefore, please fill out the attached form and have your
technical specialist and landowner sign the form in the appropriate areas.
The completed form must be submitted to this office on or before 45 days of receipt of this letter.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or liability
for failure to provide DWQ with proper notification of your conditional certification status or possible failure
to comply with the requirement to develop and implement a certified animal waste management plan by
December 31, 1997.
If you have any questions regarding this letter, please do not hesitate to contact me at [phone]
extension 571.
Sincerely,
`\�
l i
J
Sonya L. Avant
Environmental Engineer
cc: Wilmington Regional Office
Duplin County Soil and Water Conservation District
Facility File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
Mary Jernigan Hasty
Dark Hill Farm
1027 N NC 11 903 Highway
Kenansville NC 28349
Dear Mary Jemigan Hasty:
NCDENR
NoFr H CiAROLINA DEPARTMENT OF
ENVIRONMENT AND NArURAL RESOURCES
December 30, 1999
Subject: Fertilizer Application Recordkeeping
Animal Waste Management System
Facility Number 31-861
Dupiin County
This letter is being sent to clarify the recordkeeping requirement for Plant Available Nitrogen (PAN)
application on fields that are part of your Certified Animal Waste Management Plan.
In order to show that the agronomic loading rates for the crops being grown are not being exceeded, you
must keep records of all sources of nitrogen that are being added to these sites. This would include nitrogen
from all types of animal waste as well as municipal and industrial sludges/residuals, and commercial fertilizers.
Beginning January 1, 2000, all nitrogen sources applied to land receiving animal waste are required to
be kept on the appropriate recordkeeping forms (i.e. IRR1, IRR2, DRY1, DRY2, DRY3, SLUR1, SLUR2,
SLD1, and SLD2) and maintained in the facility records for review. The Division of Water Quality (DWQ)
compliance inspectors and Division of Soil and Water operation reviewers will review all recordkeeping during
routine inspections. Facilities not documenting all sources of nitrogen application will be subject to an
appropriate enforcement action.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Ms. Sonya Avant of the
DWQ staff at [phone] ext. 571.
Sincerely
Kerr T. Stevens, Director
Division of Water Quality
cc: Wilmington Regional Office
Duplin County Soil and Water Conservation District
Facility File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recyde&10% post -consumer paper

Revised Apri120, 1999
JUSTIFICATION & DOCUMENTATION FOR MANDATORY WA DETERMINATION
Facility Number_-
Farm Name: Ubll
On -Site Representative: %
Inspector/Reviewer's Name:
Date of site visit:
Operation is flagged for a wettable
acre determination due to failure of
Part Il eligibility items) F1 F2 F3 F4
Operation not required to secure WA
determination at this time based on
exemption E1 E2 (a E4
Date of most recent WUP: �- �r Operation pended for wettable acre
determination based on P1 P2 P3 .
Annual farm PAN deficit: �M pounds
irrigation System(s) - circle #hard -hose traveler, 2. center 7pivot system; 3. linear --move' system;
4, stationary sprinkler system w/permanent pipe; 5. stationary sprinkler system w/portable pipe;
G. stationary gun system w/permanent pipe; 7. stationary gun system w/portable pipe
PART 1. WA Determination Exemptions (Eligibility failure, Part 11, overrides Part I exemption.)
E1 Adequate irrigation design, including map depicting wettable acres, is complete
and signed by an I or PE.
E2 Adequate D, and D21D3 irrigation operating parameter sheets, including map
depicting wettable acres, is complete and signed by an I or PE.
E3 Adequate D, irrigation operating parameter sheet, including map depicting
wettable acres, is complete and signed by a WUP.
E4 75% rule exemption as verified in Part 111. (NOTE:75 % exemption cannot be
applied to farms that fail the eligibility checklist in Part 11. Complete eligibility
checklist, Part 11- F1 F2 F3, before completing computational table in Part 111).
PART 11.75% Rule Eligibility Checklist and. Documentation of WA Determination
Requirements. WA Determination.required.because- operation fails nne ofthe-eligibility - - ------
requirements listedbelow:
_F1 Lack of:acraagewhicn-resulteddn:over-application-zfwastewater-(PAN) on:spray.
fields) :accordingf❑farm'sdasttwoyearsmfIrrigation7.ecords.-.
F2 UnclearjIlegible. -or lack of information/map.
F3 Obviousfieldiimitations-field
buffer/setback:acreage;-�or25% of#otal-acreageidentified:.inmAWMP. Includes - -
small; -irregularly -shaped - fields - fields-lessfhan-5 acres#orfravelers-fort
2 acres#or.-stationarysprinklers).
F4 WA determination required because CAWMP credits field(s)'s acreage in excess
of 75% of the respective field's total acreage as noted in table in Part 111.

Revised April 20, 1999
Facility Number
Part III. Field by Field Determination of 75% Exemption Rule for WA Determination
TRACT
FIELD
TYPE OF
TOTAL
CAWMP
FIELD
COMMENTS3
NUMBER
NUMBER',2
IRRIGATION
ACRES
ACRES
%
SYSTEM
II kml a I I I Ito I I A
FIELD NUMBER' - hvdrant null -zone. or-ooint numbers Tnav be used in place of field numbers deoendina ❑n CAWMP
and type of irrigation -system. - If pulls, etc. cross -more -than -one field, inspector/reviewer will have to combine fields to
calculate 75% field by field determination for exemption, -otherwise operation will be subject to WA determination_
FIELD NUMBERz - must be clearly delineated nnmap. -
COMMENTS' - back-up fields with CAWMP acr-eage�exceeding75% of its total.acres and havingTeceived less than 50%
of its annual PAN as documented in the farm's previous -two years' (1997 & 1998) of irrigationTecordsr cannot serve -as -the
sole basis -for requiring a WA Determination:;Back-up:fieldsmust-bemted in the-commentzectionand must fie accessible
by irrigation -system.
Part.IV. Pending WA Determinations
P1
Plan :lacks _following information:
P2 Plan Tevision -may.satlsfy-75% rule based on adequate overall PAN deficit and by
adjusting -all field-acreage�o below 75% use rate
P3 Other (ielin process of installing new irrigation system):

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
June 26, 1998
Mary Jernigan Hasty
Dark Branch Farm
PO Box 893
Kenansville NC 28349
I ffl�!WA
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND N.nURAL RESOURCES
Subject: Reissuance of Certificate of Coverage
No.AWS310861
Dark Branch Farm
Swine Waste Collection, Treatment, Storage and
Application System
Duplin County
Dear Mary Jernigan Hasty:
The Division of Water Quality modified the Swine Waste Operation General Permit originally issued to
this facility on August 15, 1997. In accordance with the issuance of the revised General Permit, we are
forwarding this Certificate of Coverage (COC) to Mary Jernigan Hasty, authorizing the operation of the
subject animal waste collection, treatment, storage and land application system in accordance with
General Permit AWG100000. This approval shall consist of the operation of this system including, but
not limited to, the management of animal waste from the Dark Branch Farm, located in Duplin County,
with an animal capacity of no greater than 2600 Wean to Feeder and the application to land as specified
in the Certified Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003, and shall hereby void
COC No AWS310861 dated August 15, 1997. The COC shall hereby incorporate by reference any
specific conditions of the previous COC issued to this facility. The purpose of this COC is to allow
coverage under the revised General Permit. Please review the revised General Permit (enclosed) and pay
particular attention to Condition II.10 regarding tree removal from lagoon embankments, Condition III -I
regarding inspection frequency of the waste treatment, storage and collection system and Condition II1.6
regarding notification requirements for system failures, spills and emergencies. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations
as specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the
General Permit or the CAWMP may result in the revocation of this COC, or penalties in accordance
with NCGS 143-215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive
relief
P.O. Box 29535, Raleigh, North Carolina 2762E-0535 Telephone [phone] FAX 919-7'33-0719
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper
Ll\

Certificate of Coverage AWS310861
Dark Branch Farm
Page 2
Upon notification by the Division of this COC's expiration, you shall apply for its renewal_ This
request shall be made within 30 days of notification by the Division.
This COC is not automatically transferable. A name/ownership change application must be
submitted to the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the
right to apply for an individual non -discharge permit by contacting the engineer listed below for
information on this process. Unless such a request is made within 30 days, this COC shall be final and
binding.
The subject farm is located in the Wilmington Regional Office. The Regional Office Water
Quality Staff may be reached at [phone]. If you need additional information concerning this
COC or the. General Permit, please contact Mike Lewandowski at [phone] ext. 362.
Sincerely,
for A. Preston Howard, Jr., P.E.
cc: (Certificate of Coverage only for all cc's)
Duplin County Health Department
Wilmington Regional Office, Water Quality Section
Duplin County Soil and Water Conservation District
Permit File

State of North Carolina RECEIVED
Department of Environ entpEC 31 1997
LT.W*WA
and Natural Resources
Division of Water Quality BY: At
- -Oft,%
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary E:> E N
Steve W. Tedder, Chairman
Mary Jernigan Hasty
Dark Branch Farm
PO Box 893
Kenansville NC 28349
Subject: Classification of Animal Waste Management Systems
Facility: Dark Branch Farm
Facility ID #: 31-861
County: Duplin
Dear Ms. Hasty:
Senate Bill 1217, An Act to Implement Recommendations of the Blue Ribbon Study Commission on
Agricultural Waste, was enacted by the North Carolina General Assembly on June 21, 1996. This bill
requires that a certified operator be designated as the Operator in Charge (01C) by January 1, 1997, for each
animal waste management system that serves 250 or more swine, 100 or more confined cattle, 75 or more
horses, 1,000 or more sheep, or 30,000 or more confined poultry with a liquid animal waste management
system. Our records indicate that your facility is registered with the Division of Water Quality and meets
the requirements for designating an OIC.
A training and certification program is available for animal waste management system operators. For
information on the training programs please contact your local Cooperative Extension Agent. Operator
certifications are issued by the Water Pollution Control Systems Operators Certification Commission
(WPCSOCC). For information on the certification process, please contact the Technical Assistance and
Certification Unit at [phone]. The type of training and certification required for the operator of each
system is based on the nature of the wastes to be treated and the treatment process(es) primarily used to treat
the animal waste. There are two types of animal waste management systems, type A and type B. Type A
animal waste management systems are generally used to treat waste generated by monogastric animals
which produce a low -fiber waste. Type B animal waste management systems are generally used to treat
waste generated by ruminants and other animals which produce a high -fiber waste. The type of training and
certification an operator receives should correspond with the type of system(s) they intend to operate. For
more information on the classification of your system please contact the Technical Assistance and
Certification Unit
As the owner of an animal operation with an animal waste management system, you must designate an
Operator in Charge and must submit the enclosed designation form to the WPCSOCC. If you do not
intend to operate your animal waste management system yourself, you must designate an employee or
engage a contract operator to be the Operator in Charge. The person designated as the Operator in Charge,
whether yourself or another person, must possess a currently valid certificate of the appropriate type.
Sincerely,
Joseph B. McMinn, Supervisor
Technical Assistance and Certification Unit
cd/AW OIC Designation
Enclosure
cc: Wilmington Regional Office
Water Quality Files
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10%n post -consumer paper

RECEIVED
NOV 2 6 1997
BY. -
S`1IUlf PH--Y-
F A M I L Y F A R M S
October 28, 1997
North Carolina Dept. of Environment, Health & Natural Resources
Division ui Water Quahiy
Water Quality Section
Permits and Engineering Unit
P_O. Box 29535
Raleigh, NC 27626-0535
Attn: Kim H. Colson, P.E.
Re: Dark Branch Farm
COC No. AWS310861
Duplin County
Dear Mr. Colson:
On behalf of Ms. Mary Jernigan Hasty, I am writing to inform you that construction on
the above referenced facility was started before August 27, 1997. If you have any
questions, please call me at [phone] ext. 4717.
Sincerely:
�.r�
q
J. Neal Tucker, P.E.
Engineering Manager
cc: File
Ms. Mary Jernigan Hasty
Wilmington Regional Office
Post Office Box 759, Rose Hill, North Carolina 28458, [phone], FAX [phone]

State of North Carolina IT
Department of Environment,MAI
Health and Natural Resources • '
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary p G H N
A. Preston Howard, Jr., P.E., Director,
August 15, 1997
Mary Jernigan Hasty
Dark Branch Farm
PO Box 893
Kenansville NC 28349
Subject: Certificate of Coverage No. AWS310861
Dark Branch Farm
Swine Waste Collection, Treatment, Storage
and Application System
Duplin County
Dear Mary Jernigan Hasty:
In accordance with your application received on August 4, 1997, we are forwarding this Certificate
of Coverage (COC) to Farm No. 31-861, authorizing the operation of an animal waste collection,
treatment, storage and land application system in accordance with the State's General Permit (attached).
This approval shall consist of the operation of this system including, but not limited to, the management -of
animal waste from the Dark Branch Farm Farm, located in Duplin County, with an animal capacity of no
greater than 2600 Wean to Feeder and the application to a minimum of 11 acres of land as specified in the
Certified Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until December 31, 2001. Pursuant to this
COC, you are authorized and required to operate the system in conformity with the conditions and
limitations as specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of
wastes to surface waters. An adequate system for collecting and maintaining the required monitoring data
and operational information must be established for this farm. Any increase in waste production greater
than the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to actual -
increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General.
Permit or the CAWMP may result in the revocation of this COC.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This
request shall be made within 30 days of notification by the Division.
This COC is not automatically transferable. A name/ownership change application must be
submitted to the DWQ prior to a name change or change in ownership.
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

.t If any parts, requirements, or limitations contained in this COC are unacceptable, you have the
Sight to apply for an individual non -discharge permit by contacting the engineer listed below for
information on this process. Unless such a request is made within 30 days, this COC shall be final and
binding.
The subject farm is located in the Wilmington Regional Office. The Regional Office Water Quality
Staff may be reached at [phone]. If you need additional information concerning this COC or the
General Permit, please contact Mike Lewandowski at [phone] ext. 362.
incerely,
FA
A. Preston How
cc: (Certificate of Coverage only for all cc's)
Duplin County Health Department
Wilmington. Regional:Office-,Water Qdahty_SectionJ
Duplin County Soil and Water Conservation District
Permit File

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
October 17, 1997
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Mary Jemigan Hasty
PO Box 893
Kenansville NC 28349
&LT 1.K;
14
DEHNF1
Subject: Dark Branch Farm
COC No. AWS310861
Duplin County
Dear Mary Jernigan Hasty:
The subject facility was issued a Certificate of Coverage (COC) on 8/15/97 authorizing the
operation of the animal waste collection, treatment, storage, and land application system in accordance
with General Permit No. AWG100000. On Aug. 27, 1997 Governor Hunt signed into law the Clean
Water Responsibility Act- The Clean Water Responsibility. Act included several changes to -the Swine
Farm Siting Act (Siting Act) including the requirement that. all -set back :distances be -met for any swine
lagoon or swine house for which construction commences on or after the effective date of the Clean Water
Responsibility Act (Aug. 27, 1997). Before the Siting Act was amended it required the set back distances
be met at the time the swine house or lagoon was sited.: The change. in -siting requirements may apply to
your farm since construction may not have commenced by. • the effective date of the Clean Water
Responsibility Act.
Your farm was permitted prior to the effective date of the Clean Water. Responsibility Act;
therefore, you meet one of the exceptions to the moratorium. However, the farm must be re-evaluated
and, if necessary, re -designed to meet the new requirements of the Siting Act to remain covered under'the
General Permit, Within 15 days of the date of this letter, you are requested to submit, notification to the
Division of Water Quality whether the farm was under construction on or before Aug. 27, 1997.
If the farm was not under construction on or before Aug. 27, 1997, then a revised Certified Animal
Waste Management Plan must be submitted to reflect the new siting requirements. Construction not in
compliance with the Siting Act is a violation of State Statutes and the General Permit.
If you have any questions or comments concerning this matter, please contact me. at (919) 733-
5083 extension 540.
Sincerel
Kim H. Colson, P.E., Supervisor
Non -discharge Permitting Unit
cc: Wilmington Regional Office, Water Quality Section
Permit File
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

— 9y
State of North Carolina
L
IL
Department of Environment, Health and Natural Resources
Division of Water Quality
Non -Discharge Permit Application Form
General Permit - Liquid Animal Waste Operations
This application is for new or expanding facilities only. The design portions of the
Animal Waste Management Plan (AWMP) certification form, Part H, must be included
with this application prior to the application being accepted as complete. tom'
Application Date: July 28, 1997 _-crn. "
REQUIRED ITEMS CHECKLIST: ;v rn .
rn
Please indicate that you have read the following list of requirements by signing your initials in the space provided next to_Vh M 3
item.
AApnlicants' Irt�_als
1. One completed and signed original and two copies of the application for General Permit -
Animal Waste Operations;
2. Three copies of a general Iocation map indicating the location of the animal waste
facilities and field locations where animal waste is disposed-,
3. Three copies of Pages 1-3 of the Animal Waste Management PIan (AWMP) Certification
Form, including Part 11(Certification of Design Items A-F). If the facility does not have
Part 11 of the AWMP completed, it must be completed prior to submittal of a general
permit application for animal waste operations.
4" Three copies of the Animal Waste Management Plan (AWMP) used for Facility Design.
GENERAL INFORMATION:
1. Farm's Name: Dark Branch Farm
2" Print Land Owner's name: Mary 7erni an H
3" Mailing Address: PO Box 893
City: Kenansville State: NC Zip: 28349
Telephone Number. 910-296-0098
4. County where farm is located: poplin _
5. Farm Location (Direction from nearest highway. Please indicate SR numbers for state roads. Please include a copy
of a county road map with the location of the farm identified.) From Kenansville take NC 903 N for approx. 3.5 miles
to farm entrance on left
6. Print Farm Manager's Name (if different from Land Owner):
7. Lessee's / Integrator's name (if applicable; please circle which type is listed:
FORM AWO-G-NE 1/97 Page 1 of 3
14

III. OPERATION INFORMATION:
1. Farm No.: (County Number)-- (Facility Number) (only for expanding operations)
2. Please complete the table below as it applies to your facility using the certified design capacity. The "No. of
Animals" should be the maximum number for which the waste management structures were designed.
Type of Swine No. of Animals Type of Poultry No. of Animals Type of Cattle No. of Animals
® Wean to Feeder 2600 ❑ Layer ❑ Dairy
❑ Feeder to Finish ❑ Non -Layer ❑ Beef
❑ Farrow to Wean (4 sow) ❑ Turkey
❑ Farrow to Feeder (9 sow)
❑ Farrow to Finish (# sow)
Other Type of Livestock on the farm: No. of Animals:
3. Acreage cleared and available for application I I A. ; Required Acreage (as listed in the AWNT): 3.8 A
4. Number of Lagoons. 1 ; Total Capacity: 184,953 Cubic Feet (ft)
Number of Storage Ponds: ;Total Capacity: Cubic Feet (f1)
5. Are subsurface drains present within 100' of any of the proposed application fields? ❑ Yes No
6. Are subsurface drains present in the vicinity or under the proposed lagoon? ❑ Yes M No
7_ Does this facility meet the siting requirements in Senate Bill 1217? (Swine only) M Yes ❑ No
What was the date that this facility's swine houses and lagoons were sited? 7/8/97
What was the date that this facility's land application areas were sited? 7/8197
IV. APPLICANT'S CERTIFICATION:
I, Mary Jernigan Hasty (Land Owner's name listed in question 1.2), attest that this application for Dark Branch Farm
(Farm Name listed in Questions H.1) has been reviewed by me and is accurate and complete to the best of my knowledge. I
understand that if all required parts of this application are not completed and that if all required supporting information and
attachments are not included, this application package will be returned to me as incomplete.
Signature: Date:
V. MANAGER'S CERTIFICATION: (complete only if different from the Land Owner)
1, (Manager's name listed in question I.6), attest that this application for
(Farm Name listed in Question 1I.1)has been reviewed by me and is accurate and complete to
the best of my knowledge. I understand that if all required parts of this application are not completed and that if all
required supporting information and attachments are not included, this application package will be returned as incomplete.
Signature:
Date:
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
PERMITS AND ENGINEERING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0525
TELEPHONE NUMBER: [phone]
FORM AWO-GNE 1/97 Page 2 of 3

sheville Regional WQ Supervisor
9 Woodfin Place
,sheville, NC 28801
104) 251-6?A8
'ax [phone]
,very
Macon
mncornbe
Madison
lurks
McDowell
:sIdwell
Mitchell
Ierokee
Polls
:lay
Rutherford
hahatn
Swain
iaywood
Transylvania
lenderson
Yancy
acksoo
ayetteville Regional WQ Supervisor
Afachovia Building. Suite 714
?ayetteville, NC 29301
910) 4W1541
Fax [phone]
Anson
Moore
Blades
Richmond
aunberland
Robeson
Harnett
Sampson
E1oke
Scotland
4lontgontery
Washington Regional WQ Supervisor
943 Washington Square Mall
Washington, NC 27889
[phone]
Fax [phone]
Beaufort Jones
Bettie Lenoir
Chowan
Pamlico
Craven
Pasquotank
Currituck
Perquimans
Date
Pitt
Gates
Tyrell
Greene
Washington
Hertford
Wayne
3KI--
ifinston-Salem Regional WQ Supervisor
M5 Waugtuown.Stneet
Winston-Salem, NC 27107
910) 77I-4600
-ax [phone]�
llanmoe
Rockingham
Wegbany
Randolph
lshe
Stakes
:asweu
Surry
ravidsoa
Watauga
)avie
Wilkes
'orsyth
Yadkin
;uilford
Mooresvile ReZtonal WQ Supervisor
919 North Maio Stroct
Mooresville, NC 29115
[phone]
Fax [phone]
Alexander Lincoln
Cabarruus Mxkleubiug
Camwba Rogan
Cleveland Stanly
Gaston Union
htdcH
4RM= AWO-G-NE 1/97 Page 3 of 3
Raleigh Regional WQ Supervisor
3800 Barrett Dr.
Raleigh, NC 27611
[phone]
Fax [phone]
Chatham Nash
Durham Northampton
Edgecombe Orange
Franklin Person
Granville Vance
Halifax Wake
Johnston Wanes
L15C Wilson
Wilmington Region. WQ Supervisor
127 Cardinal Drive Extension
Wilmington. NC 28405-3845
[phone]
Fax [phone]
Brunswick New Hanover
Carteret Vnslow
Columbus Pender
Dupl'm

r%yA1
MURPHY
F A M 1 L Y F A R M S
August 4, 1997
North Carolina Dept. of Environment, Health & Natural Resources
Division of Water Quality
Water Quality Section
Permits and Engineering Unit
P.O. Box 29535
Raleigh, NC 27626-0535
Attn: Michael Lewandowski
Re: Permit Application for Dark Branch Swine Facility
Dear Mr. Lewandowski:
Attached you will find the permit application for the above referenced farm. Specific
items included for you review are as follows:
# Copies
Item
3
General Permit - Liquid Animal Waste Operations Application Form
3
Animal Waste Management Plan Certification Form
3
Location Map
3
Waste Management Facility Site Evaluation
3
ASCS Tract Map
3
USGS Quad Map
3
Soil Investigation Report
3
Lagoon Design Spreadsheet
3
Construction Specifications for Lagoon
3
Site Seeding Requirements
3
Operation & Maintenance Plan for Lagoon
3
Emergency Action Plan
3
Odor Control, Insect Control & Mortality Management Checklists
3
Facility Site Plans with Construction Details
3
Waste Utilization Plan
3
Irrigation Design
3rri
4
*0 Er'
xs
m
z rn
63rn
Post Office Box 759, Rose Hill, North Carolina 28458, [phone], FAX [phone]

Expeditious review and approval will be greatly appreciated. If you have any questions,
please call me at (91 Q) 289-6439 ext. 4717.
Sincerely:
'�y�
ltkt &J("�i!
J. Neal Tucker, P.E.
Engineering Manager
enclosures
cc_ File
Mary J. Hasty
Duplin County NRCS District Office

State of North Carolina
Department of Environment,
Health and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
A. Preston Howard, Jr., P.E., Director
ALT.WYVA
I DEHNF=1
R "'ClL1997
815197 AUG
MEMORANDUM BY:
To: Animal Operations Personnel, Regional Offices nn
From: JR Joshi, Soil Scientist lL
State Engineering Review Group
Subject: General Permits
Attached are copies of the permit application packages for animal waste operations. This
information is provided as reference material for your files.
The permit for each of these facilities has been signed. A copy of the permitees' Certificates of
Coverage have been sent to your attention under separate cover.
If you have any questions, please contact me at 733-5083 ext. 363.

State of North Carolina
Department of Environment,
Health and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
August 5, 1997
ALT.N?FA
14�j
C)EHNR
MEMORANDUM
To: Rick Shiver, Regional Supervisor
From: Mike Lewandowski, Environmental Enginee 4S
State Engineering Review Group
Subject: Permits Applications for New facilities
[AUG. fir-.
6 1997
BST.
Attached is a copy of the General Permit for Liquid Animal Waste Operations application package
fora new facility. This information is being provided so you may review the packages prior to
permit issuance. Please provide your comments by August 26, 1997. If no comments are
received by that date, we will assume that there are no objections, and permit issuance will
proceed.
If you have any questions, please contact me at [phone] ext. 362, or
mikelew @dem.ehnr.state.nc_us_

Animal Waste Management Plan Certification
(Please tvpepr-ant all information that does not require a sixnature)
General Information:
Name of Farm: Dark Branch Farm Facility No: --
Owner's Name: Mary lerniszan Hastv Phone No: 910-296-0098
Mailing Address: PO Box 893 ge,,fw,.sv,L.#,C N e . ze34 9
Latitude and Longitude: 35 " 0' 43" / 77 ° 54' 58" County: Du lin
;::., ..
PIease attach a copy of a county road map with location identified and describe below (Be specific: road names,
�.1¢..
rn
=
directions, milepost, etc.): From Kenansville take NC 903 N for approx. 3.5 miles to farm entrance on left
Operation Description:
to
'
Type of Swine No. of Animals Type of Poultry No. of Animals Type of Cattle No. of Animals
R'
® Wean to Feeder 2600 ❑ Layer ❑ Dairy
M v
rn
❑ Feeder to Finish ❑ Non -Layer ❑ Beef''
❑ Farrow to Wean (# sow) ❑ Turkey
❑ Farrow to Feeder (# sow)
❑ Farrow to Finish (# sow)
Other Type of Livestock on the farm: No. of Animals:
panda ig OperatId Qrtly
Pr�t?rousDesrgrz Capacity-. °rtddrtrvrrall�e�rglx Capsctf�' .`
.. �ofal Des,�11 Capacity >'
Extsttng and ExpandFng Opera#ton Only-
-- ,1�e��siration fl��, : ::.,.(Date ari whichfarnt apphed-for registration)
Acreage Available for Application: I_I A Required Acreage: 3.8 A.
Number of Lagoons/Storage Ponds: 1 Total Capacity: 18 Cubic Feet (fts)
Are subsurface drains present on the farm: YES or O (please circle one)
Owner /Manager Agreement
I (we) verify that all the above information is correct and will be updated upon changing. I (we) understand the operation
and maintenance procedures established in the approved animal waste management plan for the farm named above and
will implement these procedures. I (we) know that any expansion to the existing design capacity of the waste treatment and
storage system or construction of new facilities will require a new certification to be 'submitted to the Division of
Environmental Management before the new animals are stocked. I (we) understand that there must be no discharge of
animal waste from the storage or application system to surface waters of the state either directly through a man-made
conveyance or from a storm event less severe than the 25-year, 24-hour storm and there must not be run-off from the
application of animal waste. I (we) understand that run-off of pollutants from lounging and heavy use areas must be
minimized using technical standards developed by the Natural Resources Conservation Service. The approved plan will be
filed at the farm and at the office of the local Soil and Water Conservation District. I (we) know that any modification must
be approved by a technical specialist and submitted to the Soil and Water Conservation District prior to implementation. A
change in land ownership requires written notification to DEM or a new certification (if the approved plan is changed)
within 60 days of a title transfer.
Name of LI
caner: M Jemijzan Hass
Signature: Date: r
Name of Manager (i di rent from owner):
Signature: Date:
AWC -- April 24, 1996

Technical Specialist Certification
I As a technical specialist designated by North Carolina Soil and Water Conservation Commission pursuant to
I5A NCAC 6F .0005, I certify that the animal waste management system for the farm named above has an
animal waste management plan that meets or exceeds standards and specifications of the Division of
Environmental Management (DEM) as specified in I5A NCAC 2H.0217 and the USDA -Natural Resources
Conservation Service (MRCS) and/or the North Carolina Soil and Water Conservation Commission pursuant to
15A NCAC 2H.0217 and 15A NCAC 6F _0001-.0005. The following elements are included in the plan as
applicable. While each category designates a technical specialist who may sign each certification (SD, SI, WUP,
RC, I), the technical specialist should only certify parts for which they are technically competent.
II. Certification of Design
A) Collection Stora a Treatment System
Check the appropriate box
❑ Existing facility without retrofit (SD or WY 1P)
Storage volume is adequate for operation capacity; storage capability consistent with waste utilization
requirements. ���►►►►u„1,, 1,i�� /
New expanded or retrofitted facility (SD) ••`' Olk CARS
Animal waste storage and treatment structures, such as but no limited to collect,
Qi� $
ponds, have been designed to meet or exceed the minimum standards and speciEl ati
Q SEAL r -
Name of Technical Specialist (Please Print): . Neal Tucker a
Affiliation: Murphy Family Farms
Address (Age cy} P. . ox 159 Raw Hill NC 28458 Phone N _ 910 28g' •`
Signature: Date: '1Z 97 r�r rt ,•`•
B) Land Application_Site (WUP)
The plan provides for minimum separations (buffers); adequate amount of land for waste utilization; chosen
crop is suitable for waste management; hydraulic and nutrient loading rates.
Name of Technical Spec' list Vease Print): Kraig Westerbeek
Affiliation: Murvhv FAmihrX-arms
Address ( P 75 o 28458 Phone No.. 910 289-6439 ext. 4556
Signature: Date: '9- `%--5
C) Runoff Cont ols from Exterior Lots
Check th approp late box
f K Facility without exterior lots (SD or WUP or RC)
This facility does not contain any exterior lots.
❑ Facility with exterior lots (RC)
Methods to minimize the run off of pollutants from lounging and heavy use areas have been designed in
accordance with technical standards developed by NRCS.
Name of Technical Specialist (Please Print): Kevin Weston
Affiliation: Murnhv Familv Farms
Address (Agency): P.O. Box 759 Rose Hill, NC 28458 Phone No.: 910 289�-6439 ext.4629
Signature: svk.I✓+� _ Date: ?/z9 9N _
AWC -- April 24, 1996

D) Application and Handling_ Equipment
Check the appropriate bvx
❑ Existing or expanding facility with existing waste application equipment (WUP or 1)
Animal waste application equipment specified in the plan has been either field calibrated or evaluated in
accordance with existing design charts and tables and is able to apply waste as necessary to
accommodate the waste management plan:
(existing application equipment can cover the area required by the plan at rates not to exceed either
the specified hydraulic or nutrient loading rates, a schedule for timing of applications has been
established; required buffers can be maintained and calibration and adjustment guidance are
contained as part of the plan).
New, expanded, or existing facility without existing waste application_ equipment for
sr124yJrriSation (1)
Animal waste application equipment specified in the plan has been designed to apply waste as necessary
to accommodate the waste management plan; (proposed application equipment can cover the area
required by the plan at rates not to exceed either the specified hydraulic or nutrient loading rates; a
schedule for timing, of applications has been established; required buffers can be maintained; calibration
and adjustment guidance are contained as part of the plan).
❑ New, expanded -or existing facility without existing waste application equipment for
land spreading not using spray irrigation_ (WUP or I)
Animal waste application equipment specified in the plan has been selected to apply waste as necesary to
accommodate the waste management plan; (proposed application equipment can cover the area
required by the plan at rates not to exceed either the specified hydraulic or nutrient loading rates; a
schedule for timing of appliactions has been established; required buffers can be maintained; calibration and
.adjustment guidance are contained as part of the plan).
Name of Technical Specialist (Please Print): Gary Scalf _
Affiliation: Murphy Family Farms
Address (Agent PO $ox 759 Rose Hill NC 28458 Phone No.: /9 0--289-6439 ext 4562
Signature: _ _ Date: " 5 %
E) Odor Control, Insect Control, Mortality Management and Emergency Action Plan (SD,
SI, WUP, RC or I)
The waste management plan for this facility includes a Waste Management Odor Control Checklist, an
Insect Control Checklist, a Mortality Management Checklist and an Emergency action Plan. Sources of
both ordors and insects have been evaluated with respect to this site and Best Management Practices to
Minimize Odors and Best Management Practices to Control Insects have been selected and included in
the waste management plan. Both the Mortality Management Plan and Emergency Action Plan are
complete and can be implemented by this facility.
Name of Technical Specialist (Please Print): Kevin Weston
Affiliation: Murphy Family Farms
Address (Agency): P.O. Box 759 Rose Hill NC 28458 Phone No: [phone], ext. 4629
Signature: 1� TJ ^ Date: 7 _
F) Written Notice of New or Expanding Swine Farm
The following signature block is only to be used for new or expanding swine farms that begin
construction after June 21,1996. If the facility was built before June 21, 1996, when was it constructed
or last expanded . I (we) certify that I (we) have attempted to contact by
certified mail all adjoining property owners and all property owners who own property located across a
public road, street, or highway from this new or expanding swine farm. The notice was in compliance
with the requirements of NCGS 106-805. A copy of the notice and a list of the property owners notified
is attached.
Name of land Owner: IFnt
.l c � 14 A J
Signature: Date: �! /'—,F 7
Name of Manager (if differom o er):
Signature: Date:
AWC -- ApriI 24, 1996

Ill. Certification Of installation
A) Collection Storage, Treatment Installation
New,, expanded or retrofitted facility (SI)
Animal waste storage and treatment structures, such as but no limited to lagoons and ponds, have been installed
in accordance with the approved plan to meet or exceed the minimum standards and specifications.
For existing facilities without rehrofits, no cerfiftcation is necessary.
Name of Technical Specialist (Please Print): '). Neal Tucker
Affiliation: Murphy Family Farms
Address (Agency): P. O. Box 759 Rose Hill NC 28458 Phone No.: [phone], ext. 4717
Signature: Date:
B) Land Application Site (V17UP)
Check the appropriate box
❑ The cropping system is in the place on all land as specified in the animal waste management plan.
❑ Conditional Approval: all required land as specified in the plan is cleared for planting; the cropping
system as specified in the waste utilization plan has not been established and the owner has committed
to establish the vegetation as specified in the plan by (month/day/year); the proposed cover
crop is appropriate for compliance with the waste utilization plan.
❑ Also check this box if appropriate if the cropping system as specified in the plan can
not be established on newly cleared land within 30 days of this certification, the owner
has committed to establish an interim crop for erosion control;
Name of Technical Specialist (Please Print): Kraig Westerbeek
Affiliation: Murphymurphy family Farms
Address (Agency): P. O. Box 759 Rose Hill NC 28458 Phone No.: [phone], ext. 4556
Signature: Date:
This following signature block is only to be used when the box for conditional approval in III. B above has been
checked.
I (we) certify that I (we) have committed to established the cropping system as specified in my (our) waste
utilization plan, and if appropriate to establish the interim crop for erosion control, and will submit to DEM a
verification of completion from a Technical Specialist within 15 calendar days following the date specified in the
conditional certification. I (we) realize that failure to submit this verification is a violation of the waste
management plan and will subject me (us) to an enforcement action from DEM.
Name of Land Owner:
Signature: Date:
Name of Manager (if different from owner):
Signature:
AWC -- April 24, 1996 4
Date:

C) Runoff Controls from Exterior Lots (RC)
Facility with exterior lots
Methods to minimize the run off of pollutants from lounging and heavy use areas have been installed as
specified in the plan.
For facilities without exterior lots, no certffication is necessary.
Name of Technical Specialist (Please Print):
Affiliation:
Address (Agency): Phone No.:
Signature: Date:
D) Application and Handling Equipment Installation (WUP or I)
Check the appropriate block
❑ Animal waste application and handling equipment specified in the plan is on site and ready for
use; calibration and adjustment materials have been provided to the owners and are contained
as part of the plan.
❑ Animal waste application and handling equipment specified in the plan has not been installed
but the owner has proposed leasing or third party application and has provided a signed
contract; equipment specified in the contract agrees with the requirements of the plan; required
buffers can be maintained; calibration and adjustment guidance have been provided to the
owners and are contained as part of the plan.
❑ Conditional approval: Animal waste application and handling equipment specified in the plan
has been purchased and will be on site and installed by (month/day/year); there is
adequate storage to hold the waste until the equipment is installed and until the waste can be
land applied in accordance with the cropping system contained in the plan; and calibration and
adjustment guidance have been provided to the owners and are contained as part of the plan.
Name of Technical Specialist (Please Print): Ca Scalf
Affiliation: Mur2hy Family Farms
Address (Agency): P. O. Box 759 Rose Hill, NC 28458 Phone No.: [phone], ext. 4562
Signature: - Date:
The following signature block is only to be used when the box for conditional approval in III D above has been
checked.
I (we) certify that I (we) have committed to purchase the animal waste application and handling equipment as
specified in my (our) waste management plan and will submit to OEM a verification of delivery and installation
from a Technical Specialist within 15 calendar days following the date specified in the conditional certification. I
(we) realize that failure to submit this certification is a violation of the waste management plan and will subject
me (us) to an enforcement action from OEM.
Name of Land Owner:
Signature : Date:
Name of Manager (if different from owner):
Signature: Date:
AWC -- April 24, 1996 5

E) Odor Control, Insect Control and Mortality Management (SD, SI, WUP, RC or 1)
Methods to control odors and insects as specified in the Plan have been installed and are
operational. The mortality management system as specified in the Plan has also been installed
and is operation.
Name of Technical Specialist (Please Print): Kevin Weston
Affiliation: Murphy Family Farms
Address (Agency): P. O. Box 759 Rose Hill, NC 28458 Phone No: [phone], EXT. 4629
Signature: Date:
Please return the completed form to the Division of Environmental Management at the following address:
Department of Environment, Health, and Natural Resources
Division of Environmental Management
Water Quality Section, Compliance Group
P. O. Box 29535
Raleigh, NC 27626-0535
Please also remember to submit a copy of this form along with the complete Animal Waste Management Plan to
the local Soil and Water Conservation District Office and to keep a copy in your files with your Animal Waste
Management Plan.
AWC — April 24, 1996

Hill
liNA—BEM—WO
tuRMITS. &INGIN. UNIT;
97 AUG —4
(ILI
16
to
w
to
dk
ce rva I't
al
17A

MURPHY FAMILY FARMS
WASTE MANAGEMENT FACILITY SITE EVALUATION
Name !z'r 1kFX11, 4A-" IIA s rr
�ENgN5y%i� AJ[
Telephone 91,o - - o0 98
Location Data
Distance from nearest residence not owned by producer:
Is site within 100 year flood plain?
Is site at least 100 feet from a "Blue Linc" perennial stream?
If no, site must be relocateA
Is site within 1 mile zoning jurisdiction of a municipality?
If yes, site must be relocated.
Are there utilities in the construction area?
Wetlands
Will site involve clearing woodlands or any non -cropland?
Size Operation Zl cy
If wetlands are involved, it is the responsibility of the producer
to obtain all necessary permits before any clearing is done.
Other Environmental Factors
Is endangered and/or threatened species habitat present?
Is a designated natural scenic area included in the planning
area or will planned actions impact on an adjacent natural
scenic area?
Is an archaeological or historical site located in the planned area?
Are cultural resources present?
/ Gov ' -
Yes No
r

Waste Management
Does producer own enough land to properly land apply waste?
If no, does producer have access to more land?
If land is not owned by producer, can producer get agreement
for land on which to apply waste?
Soil Investigation
Is soil suitable for lagoon?
Is a clay liner required?
If yes, is clay available on site?
Yes No
Questionable
Is a core trench required?
Test holes will be dug initially in the general area of proposed lagoon. It during design, the
position of the lagoon is changed to an area where no test holes were pEo ousiy_dug, additional
test holes WILL be required.
Comments
This site investigation is valid as long as the design and construction of lagoon continues
in a reasonable time period. Undue delays or hesitancy in construction may require that site
be re-evaluated.
Evaluator J / G/
(MFF Engineering)
Signature
(Producer)
Date 7 �' 97
Date

1\
No
Beds ���".
l �r,' �/ �✓
�P
� •
M.
\\ �' I n ,
I 9 ~r r �/I 'r • /^
30
' s' err
C
�,(
1 1�l` �•,
�/
qf-
rr" __�
r''{\ �µ�.3 p �h -. ..Ijli 1 37.5' ---�` �—
k',.'ail �. it
'1 h
�fil `�
IIJj�Lr�
J �.,�--��,.,�—�
• • i
II �� /• �� I1•
�I \.r•� �J r� r� J//' r'' �/ \�/' .`\ �.r \�39_S
,0 1 r
0
2.0
Cep
,l
J
Hilton 40
tii
LL\ �"' CEm �
32.'Crylvary I. o
!f( Ch ernfe
��we
Chl PET
1
it , •' �
� �\ f'
�`\ .° � > \ } i
Ill �/
Tim
=
40,
%�../P
rKFNANSV111F!
5453 IV NW ,,� .._.....,.,..� o R'n I` 55' '34 235
SCALE 1:24 000 '� n
1 g C
0 KILO ETERS } 2 tl ;009 0 METERS
1000 2000
-- 5 0 3
MILES {�
_.— „0— }000 2006 3090 400D nF" 50pD G000 1000 8p0 0 �gppp�0
-- - H Z
H
W i NTERiOA_OEOLOOIC/.L Su RvET, REST
'36
ROAD CLASSIF74CAJ
Primary highway, Ught•dt
hard Surface ...� imprOVE
Secondary highway,
hard surface... �. unimpr
InIPr'.IAt(, Pr, i,tn 11 0 n

I
—ne
� I T
7%­ T11 t-4- _Vr
lit
-.1 F J P,
xy/ . . . . . . . . . . . . . . .
q. A
eo-
"OjI

LAGOON SITE SOILS INVESTIGATION
PROJECT: Jn,4z� �EJ?N,�dN N4srr COUNTY:
FIELD INVESTIGATION BY:k,-s DATE: 7/1/%7
SITE SKETCH
cy
Nu
BORING
NUMBER
AND PROFILE
DEPTH WT 11DEPTH
I WT
D- I"
3"
J� 3
2-o
/•S 7
f3c+�K f (,pA G+r,.E r� 7e.- E''
/ •� f
Oti l7✓` OrA7 I/%102 W .A,Jb f
71 /O.
//A
GAY rJ S0f �A,J� (Ce r�cri }
L
Lf aLr Gu�Y �aF (O�I14F rvr-'c i C/_">f ',r'
/I 45�
�fcr/ his C. - S.�o w
Y r i lJr , rz 5!! r w ,-,o r s-,rr eta F- 7 !y p
t0 �, s.,✓G p / '
C
D- J
L
t
[ 3
r-
RN % V`N� I -/a .rF ,a11y
/9.S
(/
�,� %
r% f �i4Y✓a
2 •- / '
14
7" ! I
7� X�
cggA� ldv •)r j;!T iwro/
/I'-
"It a[a S.r.- tear :f Si+:,o 1 Ccn•r�S ;,4f��
O = fl '
laJ�/J7 vlr9Nr TAB ivr !a �>]
P
4G•t Gr`+y R'r oA R E ,ten .k 1. �p r 5,�,�0
H=o RN,r,rb .. C I,.
BORING/SAMPLING METHOD: �nralcP SIGNATURE:

LAGOON SITE SOILS INVESTIGATION
PROJECT: M��Y , f/+,r, COUNTY:
FIELD INVESTIGATION BY: /Z--' DATE:
BORING NUMBER AND PROFILE
DEPTH WT DEPTH WT
L,./�� y �QQ •� d/. �i�<-ter 7t �X: /
+� / I �jL�c: d f�lzi7 p'ir+•r i.!•"r' 7f'Lr i��
/77
7�/f /�i<Cti= f1� �.K SC la �+F � `r.a .fa ��.�,•
BORING / SAMPUNG METHOD: C x C4,/,A, PP- SIGNATURE:

UKUWLH: MAHY JtHNIUAN HA51 Y t-AHM 1.1t�1UrgtU t3Y: JJU
ADDRESS: P.O. BOX 893 CHECKED BY: JST
KENANSVILLE, NC 28349 DATE: 07/18/97
COUNTY: DUPLIN SHEET 1 OF 3
SPECIFICATIONS FOR CONSTRUCTION OF WASTE TREATMENT LAGOONS
FOUNDATION PREPARATION:
The foundation area of the lagoon embankment and building pad shall be cleared of
trees, logs, stumps, roots, brush, boulders, sod, and rubbish. Satisfactory disposition
c
will be made of all debris. The topsoil from the lagoon and pad area should be stripped'
c�
and stockpiled for use on the dike and pad areas. After stripping, the foundation area
4-
of the lagoon embankment and building pad shall be thoroughly loosened prior to placing ,
the first lift of fill material to get a good bond.
_.
.
EXCAVATION AND EARTHFILL PLACEMENT
t
!r
The completed excavation and earthfjll shall conform to the lines, grades, and elevations
shown on the plans. Earthfill material shall be free of material such as sod, roots, frozen
soil, stones over 6 inches in diameter, and other objectionable material. To the extent they
are suitable, excavated material may be used as fill. The fill shall be brought up in
approximately horizontal layers not to exceed 9 inches in thickness when loose and prior
to compaction. Each layer will be compacted by complete coverage with the hauling and
spreading equipment or standard tamping roller or equivalent method. Compaction will
be considered adequate when fill material is observed to consolidate to the point that
settlement is not readily detectable. NOTE THE SPECIAL REQUIREMENTS FOR
PLACEMENT OF LINERS IN THE LINER SECTION OF THIS SPECIFICATION.
The embankment of the lagoon shall be installed using the more impervious materials from
the required excavations. Construction of fill heights shall include 5 percent for settlement.
Dikes over 15 feet in height with an impoundment capacity of 10 acre—feet or more fall
under the jurisdiction of the NC Dam Safety Law and require permitting by the NC Dept of
Environment, Health and Natural Resources, Land Quality Section. The height is defined
as the difference in elevation from the constructed height to the downstream toe of the dike.
Precautions shall be taken during construction to prevent excessive erosion and
sedimentation.
LINER:
THE MINIMUM REQUIRED CLAY LINER THICKNESS SHALL BE 1.6 FT.
NOTE: LINERS (PARTIAL OR FULL) ARE REQUIRED WHEN INDICATED ON THE
DRAWINGS OR WHEN MATERIAL IS ENCOUNTERED DURING CONSTRUCTION THAT
WILL NOT PROVIDE THE PERMEABILITY LIMITS AS STATED LATER IN THIS SECTION.
SUCH MATERIAL IS CONSIDERED UNSUITABLE WITH RESPECT TO LINING. A TYPICAL
CROSS SECTION OF THE LINER IS INCLUDED IN THE DRAWINGS WHEN LINERS
ARE REQUIRED.
Murphy Family Farms Engineering P.O. Box 759, Rose Hill NC 28458 [phone]

GROWER: MARY JERNIGAN HASTY FARM DESIGNED BY: JJD
ADDRESS: P.O. BOX 893 CHECKED BY: JST
KENANSVILLE, NC 28349 DATE: 07/18/97
COUNTY: DUPLIN SHEET 2 OF 3
When areas of unsuitable material are encountered, they will be overexcavated below
finish grade to the specified depth as measured perpendicular to the finish grade. The
foundation shall be backfilled as specified to grade with a material approved by the
engineer or his representative.
REFER TO THE DRAWINGS FOR SPECIAL CONSIDERATIONS.
Soil liner material shall come from an approved borrow area. The minimum moisture
content of the liner material shall be optimum moisture content which relates to that
moisture content when the soil is kneaded in the hand it will form a ball which does not
readily separate. Water shall be added to borrow as necessary to insure proper moisture
content during placement of the liner. The moisture content of the liner material shall not
be less than optimum moisture content during placement. The maximum moisture
content relates to the soil material being too wet for efficient use of hauling equipment and
proper compaction. Proper compaction of the liner includes placement in 9 inch lifts and
compacted to at least 95 percent of the Standard Proctor Maximum Dry Density
(ASTM D698) of the liner material. When smooth or hard, the previous lift shall be scarified
and moistened as needed before placement of the next lift.
The single most important factor affecting the overall compacted permeability of a clay
liner, other than the type of clay used for the liner, is the efficient construction processing
of the compacted liner. The sequence of equipment in an established pattern helps
assure uniformity in the entire placement and compaction process. For most clay soils, a
tamping or sheepsfoot roller is the preferred type of compaction equipment.
In accordance with NRCS South National Technical Center (SNTC) Technical Note 716
(revised September 1993) the maximum allowable specific discharge of the liner is
1.0 x 10-5 cm/sec. This specific discharge is dependant on the permeability of the
liner material, the liner thickness, and the hydrostatic pressure on the liner. With the
minimum required liner thickness stated earlier and the maximum liquid depth in the
lagoon, the maximum permeability of the compacted liner is 1.25 x 10-6cm/sec. Upon
completion of the liner, undisturbed samples will be taken and tested for actual
permeability. Any permeability tests indicating a higher permeability than stated above
will be considered as failing. Failing tests will require recompaction of the liner material
and retesting.
For lagoons being built in soils which do not require clay lining the same permeability
requirements apply as for clay liners and testing of the in —situ material will be conducted.
During the excavation process, soils at the excavated surface are loosened as adjacent
material is being removed. As a result, the permeability of these surface soils is increased.
To insure proper compaction and minimum soil permeability, when lagoon excavation is
complete the inner side slopes and bottom shall be rolled thoroughly prior to testing.
Murphy Family Farms Engineering P.O. Box 759, Rose Hill NC 28458 [phone]

ADDRESS: P.O. BOX 893
KENANSVILLE, NC 26349
JVVII.IIVV V I • VVV
CHECKED BY: JST
DATE: 07/18/97
SHEET 3 OF 3
The soil liner shall be protected from scour produced by the discharge from waste outlet
pipes. This can be done by using some type of energy dissipator: concrete flumes,
concrete blocks laid tightly together, or using flexible pipe outlets on waste pipes.
Alternatives to soil liners are synthetic liners and bentonite sealant. When these are
specified, additional construction specifications are included with this Construction
Specification or are shown on the drawings.
CUTOFF TRENCH:
A cutoff trench shall be constructed under the embankment area when called for in the
notes on the drawings or as shown on atypical cross section on the drawings. The final
dimensions of the cutoff trench shall be determined by observation of the foundation
materials during construction.
VEGETATION:
All exposed embankment and other bare constructed areas shall be seeded to the
planned type of vegetation as soon as possible after construction according to the
seeding specifications. Topsoil, if available on site should be placed on areas of the dike
and pad to be seeded. Temporary seeding or mulch shall be used if recommended
permanent vegetation is out of season dates for seeding. Permanent vegetation should
be established as soon as possible during the next period of approved seeding dates.
REMOVAL OF EXISTING TILE DRAINS:
An observation trench shall be dug along the perimeter of the lagoon 25 feet outside the
proposed embankment toe to verify that no subsurface drain the lines are present in the
lagoon area. The trench shall be dug to a minimum depth of five feet and shall have a width
adequate to accommodate equipment used for backfill and compaction. Trench side
slopes shall be 1:1 or flatter. Trench backfill shall be compacted as stated in the
EXCAVATION AND EARTHFILL PLACEMENT section of the specification.
When tile drains are encountered, the tile will be removed to a minimum of 25 feet beyond
the outside toe of slope of the dike. The tile trench shall be backfilled and compacted with
material approved by the engineer or his representative. Tile drains that are removed
shall be either capped off or rerouted around the lagoon, as directed by the engineer or
his representative.
SAFETY AND HEALTH REQUIREMENTS:
All operations shall be carried out in a safe, skillful, and workmanlike manner. All safety and
health regulations shall be observed and appropriate personal safety and health measures
used at all times during construction.
Murphy Family Farms Engineerntg P.O. Box 759, Rose H111 NC 28458 [phone]

Grower: MARY JERNIGAN HASTY FARM Designed By: JJD
Address: P.O. BOX 893 Checked By: JST
KENANSVILLE, NC 28349 Date: 07/18/97
Coun : DUPLIN Sheet 1 of 7
ANAEROBIC WASTE LAGOON DESIGN
FARM INFORMATION
Farm Population:
Nursery:
Finishing:
Farrow to weanling:
Farrow to feeder:
Farrow to finish:
Boars:
Storage Period:
25 Yr. / 24 Hr Storm Event
"Heavy Rain" Factor
Rainfall in Excess of Evaporation
Additional Water Usage:
Additional Drainage Area
LAGOON INFORMATION
Is Lagoon Designed as an Irregular Shape? (Y/N)— — — — — — — — — — Y
Does Operator Want Emergency Spillway? (Y/N) — — — — — — -- - — —N
2600 Hd.
0
0
0
0
0
180 Days
7.5 In.
7.5 In.
7.0 In.
0
0
Is This Design for an Existing Farm? (Y/N) — — — — — — — — — —N
Is Drain Tile Req'd to Lower SHWT? REQUIREDIIIIII! Y
Seasonal High Water Table Elev:— — — — — — — — — — — — — — — — — — —
99.50 Ft.
Freeboard: — — — — — — — — — — — — — — — — — — —
1.0 Ft.
Emergency Spillway Flow Depth: Not Applicable
0
Top of Storm / Spillway Buffer: Not Applicable
0
Side Slopes: — — — — — — — — — — — — — — — — — — —
3 :1 (H:V)
Press ALT—C to Download
0.0
contour areas see sheet 2 of 7...
0.0
Top of Dike Elevation: — — — — — — — — — — — — — — — — . --
104.10 Ft.
Finished Bottom Elevation: -- — — — — — — — — — — — — — — — — — —
93.10 Ft.
Start Pump Elevation: — — — — — — — — — — — — — — — — — — —
101.50 Ft.
Stop Pump Elevation: ---------------------
99.20 Ft.
LAGOON VOLUME REQUIREDVOL. DESIGN VOLUMES
% REQ'D.
Storm Stor = 38298 (Cu.Ft.) 43,010 (Cu.Ft.)
11230%
Temporary = 49156 (Cu.Ft.) 53,591 (Cu.Ft.)
109.02%
Permanent = 97500 Cu.Ft. 99,347 Cu.Ft.
101.89%
Total Volume = 184,953 (Cu.Ft.) 195,948 (Cu.Ft.)
105.9411/6
Min. Required Liner Thickness -------------------- 1.6 Ft.
Lagoon Surface Area: (Inside TOD)-------------------- 30,638 S.F.
Murphy Family Farms Engineering P.Q. Box 759, Rase Hill NC 28458 [phone]

Address: P.Q. BOX 893
KENANSVILLE, NC 28349
Countv: DUPLIN
)esigned By:
Checked By:
Date:
ACTUAL DESIGN VOLUME CALCULATIONS
2 of 7
JST
07/18/97
LAGOON STAGE -AREA VOLUMES
Contour
Elevation (Fr.)
Area SF
Incr. Vol. (Cu. FT)
Cumul. VoL (Cu. FTC
93.10
11,793
94.00
13,008
11,160
11,160
95.00
14,426
13,717
24,877
96.00
15,916
15,171
40,048
97.00
17,478
16,697
56,745
98.00
19,112
18,295
75,040
99.00
20,818
19,965
95,005
100.00
22,596
21,707
116,712
101.00
24,447
23,522
140,234
10200
26,369
25,408
165,642
103.00
28,363
27,366
193,008
104.00
30,429
29,396
222,404
104.10
30,638
3,053
225,457
END PUMP = = = = >
99.20
FT
99,347 CF
TR'MT
99,347
101.89%
START PUMP = = = >
101.50
FT
152,938 CF
TEMP
53,591
109.020/6
MAX STORAGE = = >
103.10
FT
195,948 CF
STORM
43,010
112300/
Murphy Family Farms Engineering P. O. Box 759, Rose Hill NC 28458
[phone]

Grower: MARY JERNIGAN HASTY FARM Designed By. JJD
Address: P.O. BOX 893 Checked By: JNT
KENANSVILLE, NC 28349 Date: 07/18/97
Countv: DUPLIN Sheet 3 of 7
MINIMUM REQUIRED VOLUME CALCULATIONS
Permanent Storage:
Required Treatment Volume:
Animal Type Capacity * ALW * cu.ft. Ib = Total
Nursery__2,600
30
1.00
78,000
Finishing
0
135
1.00
0
Farrow to weanling
0
433
0.67
0
Farrow to feeder
0
522
0.67
0
Farrow to finish
0
1,417
1.0010
Boars
01
4001
q.501
0
Total Required Treatment Volume (cu. ft.) = 78,000
Sludge Storage Volume:
Animal TTpe Ca aci * ALW * cu.ft Ib = Total
Nursery
2,6001
30
0.25
19,500
Finishing
0
135
0.25
0
Farrow to weanling
Oi
433
0.17
0
Farrow to feeder
0
522
0.17
0
Farrow to finish
01
1,4171
0.2510
Boars
01
4001
0.1251
0
Total Required Sludge Storage Volume (cu. ft.)= 19,500
Temporary Storage Volume:
Manure Production:
nima e a aci to. erio a s . ay) = ota
Nursery
2,600
180
0.30
140,400
Finishing
0
180
1.40
0
Farrow to weanling
0
180
4.30
0
Farrow to feeder
0
180
4.50
0
Farrow to finish
0
1801
13.501
0
Boars
0
180
t 4.001
0
Total Manure Production (gals.)= 140,400
Total Manure Production (cu.ft.)= 18,770
Excess Fresh Water:
Animal Type Ca aci * Sto. Period * als Hd, da = Total
Nursery
2,600
180
0.20
93,600
Finishing
0
180
0.90
0
Farrow to weanling
0
180
2.90
0
Farrow to feeder
01
180
3.50
0
Farrow to finish
01
1801
9.501
0
Boars
01
180
2-70_L
0
Total t-resh Water Excess (gals.) = 93,600
Total Fresh Water Excess (cu.ft.)= 12,513
Murphy Family Farms Engineern•rg P.O. Box 759, Rose Hill NC 28456 (M) 289-2111

Address: P.O. BOX 893 Checked By: JST
KENANSVI LLE, NC 28349 Date: 07/18/97
Countv: DUPLIN Sheet 4 of 7
Temporary Storage Volume: (Cont.)
Rainfall in Excess of Evaporation:
Vol. = (Lagoon Surface Area + Additional Drainage Area) * Rainfall / 12in./ft
Vol. _ (30638 sq.ft. + 0 sq.ft.) * 7 in. /12 in./ft.
Total Required Volume for Rainfall in Excess of Evap. (cu.ft.)= 17,872
Storm Storage:
Vol.=(Lagoon Surf. Area + Addt'I Drainage Area) * 25Yr./24Hr. Storm(in) / 12in./ft.
Vol.= (30638 sq.ft + 0 sq.ft.) * 7.5 in. /12 in./ft.
Total Required Volume for 25Yr.-24Hr. Storm Event (cu.ft)= 19,149
"Heavy Rain" Storage:
Vol. =(Lagoon Surf. Area + Addt'I Drainage Area) * "Heavy Rain" Factor (in) / 12in./ft.
Vol._ (30638 sq.ft + 0 sq.ft.) * 7.5 in. /12 in./ft. -
Total Required Volume for'Heavy Rain' (cu.ft.) = 19,149'
(for Extended Periods of Chronic Rainfall)
Additional Water Storage:
No Additional Water Storage is Required
Total Required Storm Storage
(25 Yr. / 24 Hr. Storm + "Heavy Rain") = 38,298 (CU.FT)
Total Required Temporary Storage
(Manure Prod. + Excess Fr. Water + Rainfall Excess) .= 49,156 (CU.FT)
Total Required Permanent Storage
(Treatment + Sludge) = 97,500 (CU.FT)
TOTAL REQUIREDVOLUME= 184953 (CU.FT.)
Murphy Family Farms Engineering P.0. Box 759, Rose Hill NC 28458 (910) 289-21 l 1

Address: P.O. BOX 893 Checked By: JST
KENANSVILLE, NC 28349 Date: 07/18/97
Countv: DUPLIN Sheet 5 of 7
LAGOON DESIGN SUMMARY
Top of Dike Elevation ---------------------
Emergency Spillway Crest Elevation --------------------
Top of 25 yr/24 hr Storm Storage --------------------
Top of "Heavy Rain" Storage - -----------------
Start Pump Elevation --------------------
End Pump Elevation --------------------
Top of Sludge Storage -------------------
Seasonal High Watertable Elev. --------------------
Finished Bottom Elevation -------------------
Inside Top Length -------------------
Inside Top Width -------------------
Side Slopes ----------------------
Lagoon Surface Area -------------------
Min. Liner Thickness (if required) --------------------
Freeboard Depth --------------------
Temporary Storage Period - - - - - - - - - - - - - - - - - - -
Zone De ths:
104.10 FT.
Not Applicable
103.10 FT.
102.24 FT.
101.50 FT.
99.20 Ff.
94.61 FF.
99.50 FT.
93.10 FT.
Not Applicable
Not Applicable
3:1 H:V
30,638 SF
1.6 FT.
1.00 FT.
180 Days
TOTAL DESIGN VOLUME = 195948 (CU.FT.)
Treatment / Sludge Storage Zone Depth - - - - - - - - - - - 6.1 FT.
Temporary Storage Zone Depth - - - - - - - - - - - 2.3 FT.
Freeboard / Storm Storage Zone Depth - - - - - - - - - - -- 2.6 FT.
Total Lagoon Depth - - - - - - - - - - - 11.0 FT.
Murphy Family Farms Engineering P.O. Box 759, Rose Hill NC 284W [phone]

Grower: MARY JERNIGAN HASTY FARM Designed By: JJD
Address: P.O. BOX 893 Checked By: JST
KENANSVILI E, NC 28349 Date: 07/18/97
Countv: DUPUN Sheet 6 of 7
ZONE ELEVATIONS
TOP OF DIKE ELEV = 104.10
1 1 1 1
/ 1 TOP OF STORM ELEV = 103.10 / 1
1 1 1 1
1 TOP OF HEAVY RAIN ELEV = 102.24 /
1 1
STRT PMP EL.= 101.50 1 TOP OF TEMP STORAGE ELEV = 101.50 /
1 1
END PMP EL. = 99.20 1 TOP OF TREAT ELEV = 99.20 1 SHM = 99.50
Aliimhv Family Farmc Fr►rvimaarinn
1 1
1 1
TOP OF SLUDGE ELEV = 94.61 1
1. 1
FINISHED BOTTOM ELEV = 93.10
P (] Rnx 759 Rasp Hill NC 28458
MID) 289-2111

�,
Address: P.O. BOX 893
KENANSVI LLE,
County: DUPLIN
Checked By:
NC 28349 Date:
Sheet 7 of 7
JST
07/18/97
This livestock waste treatment lagoon is designed in accordance with the North Carolina
Natural Resources Conservation Service PRACTICE STANDARD 359— WASTE TREATMENT
LAGOON, revised in September, 1996.
Emergency Spillway:
An Emergency Spillway is not required.
SHWT:
Subsurface drain the will be installed adjacent to the lagoon as shown on the site
drawing. The tile is being installed to keep the seasonal high water table adjacent
to the lagoon at or below the stop pump elevation.
NOTE: See attached Waste UtilizatiorR+++,,,��
110
Ik CA
DESIGNED:
SEAL
- 14985 ;
DATE: 71 V -7 FN
COMMENTS: The lagoon has been designed as anirrta"r shape
Actual contour areas taken from the lagoon design are used to calculate
the surface area and storage volume characteristics of the lagoon.
This approach insures that rainfall capture on the lagoon is fully
accounted for and that storage volumes calculated represent actual
conditions regardless of the shape.
Murphy Family Farms Engineer�ng P. O. Box 759, Rose Hill NC 28458
[phone]

ADDRESS: P.O. BOX 893 CHECKED BY:
KENANSVILLE, NC 28349 DATE:
COUNTY: DUPLIN SHEET
SEEDING SPECIFICATIONS
ACREAGE TO BE SEEDED: 3.0 ACRES
USE THE SEED MIXTURE INDICATED AS FOLLOWS:
180 LBS. FESCUE GRASS AT 60 LBS./ACRE
(BEST SUITED ON CLAYEY OR WET SOIL CONDITIONS)
SEEDING DATES: SEPTEMBER 1 TO NOVEMBER 30
FEBRUARY 1 TO MARCH 30
JST
07/18/97
OF 1
90 LBS. RYE GRAIN AT 30 LBS./ACRE (NURSERY FOR FESCUE)
180 LBS. 'PENSACOLA' BAHIA GRASS AT 60 LBS./ACRE
(SEE FOOTNOTE NUMBER 1)
SEEDING DATES: MARCH 15 TO JUNE 15
24 LBS. HULLED COMMON BERMUDA GRASS AT 8 LBS./ACRE
(SUITED FOR MOST SOIL CONDITIONS)
SEEDING DATES: APRIL 1 TO JULY 31
y
x�
30 LBS. UNHULLED COMMON BERMUDA GRASS AT 10 LBS./ACRE
SEEDING DATES: JANUARY 1 TO MARCH 30
120 LBS. RYE GRASS AT 40 LBS./ACRE (TEMPORARY VEGETATION)
SEEDING DATES: DECEMBER 1 TO MARCH 30
APPLY THE FOLLOWING:
3000 LBS. OF 10-10-10 FERTILIZER (1000 LBS./ACRE)
6 TONS OF DOLOMITIC LIME (2 TONS/ACRE)
300 BALES OF SMALL GRAIN STRAW (100 BALES/ACRE)
ALL SURFACE DRAINS SHOULD BE INSTALLED PRIOR TO SEEDING. SHAPE ALL
DISTURBED AREAS IMMEDIATELY AFTER EARTH MOVING IS COMPLETED.
APPLY LIME AND FERTILIZER THEN DISK TO PREPARE A 3 TO 4 INCH SMOOTH
SEEDBED. APPLY SEED ANDFIRM SEEDBED WITH A CULTIPACKER OR SIMILAR
DEVICE. APPLY MUCH AND SECURE WITH AN ANCHORING TOOL OR NETTING.
1. PENSACOLA BAHIA GRASS IS SLOWER TO ESTABLISH THAN COMMON
BERMUDA GRASS. WHEN USING BAHIA, IT IS RECOMMENDED THAT 8
LBS./ACRE OF COMMON BERMUDA BE INCLUDED TO PROVIDE COVER UNTIL
BAHIA GRASS IS ESTBLISHED.
Murphy Family Farms Engineering P.O. Box 759, Rose Hill NC 26458 [phone]

ADDRESS: P.O. BOX 893
KENANSVILLE, NC 28349
COUNTY: DUPLIN
CHECKED BY:
DATE:
SHEET
OPERATION AND MAINTENANCE PLAN
This lagoon is designed for waste treatment (permanent storage) and 180 days of"
temporary storage. The time required for the planned fluid level (permanent and
temporary storage) to be reached may vary due to site conditions, weather, flushing
operations, and the amount of fresh water added to the system.
.1ST
E
The designed temporary storage consists of 180 days of temporary storage for:
(1) manure production of animals, (2) excess fresh water storage, (3) rainfall in
excess of evaporation, (4) storage for the 25 year / 24 hour storm for the location,
(5) and, if applicable, an additional "heavy rain" storage volume for chronic rainfall
events. Allocation for any additional fresh water usage is also included in the
temporary storage. The volume of waste generated from a given number of animals
will be fairly constant throughout the year, but excess rainfall will vary from year to year.
The 25 year rainfall will not be a factor to consider in an annual pumping cycle, but
this storage volume must always be available.
07/18/97
A staff gauge must be installed in the lagoon that indicates the start pumping and stop
pumping levels. The start pumping level is the maxium liquid level under normal operating
conditions. The stop pumping level is the minimum liquid level under normal
operation to maintain required treatment volume and depth. Pumping can be started
and stopped anywhere between these two elevations for operating convenience as site
conditions permit, such as weather, soils, crop, and equipment in order to apply waste
without runoff or leaching. However, it is recommended that the lagoon be kept
pumped down as much as possible.
Land application of wastewater is recognized as an acceptable method of disposal.
Methods of application include solid set, center pivot, guns, and traveling guns. Care
should be taken when applying waste to prevent damage to crops.
The following items are to be carried out:
�1
1. It is required that the treatment lagoon be precharged to.one—half the treatent volume
or as otherwise specified on the lagoon design drawings before wastes are introduced.
The purpose is to prevent excessive odors during start—up. Precharging reduces the
concentration of the initial waste entering the lagoon thereby reducing odors. Solids should
be covered with effluent at all times. When precharging is complete, flush buildings with
recycled lagoon liquid. Fresh water should not be used for flushing after initial filling.
2. The attached Waste Utilization Plan shall be followed. The plan recommends
sampling and testing of waste before land application.
Murphy Family Farms Engineering P.O. Box 759, Rose Hill NC 28458 [phone]
m
rn

ADDRESS: P.O. BOX 893 CHECKED BY: JST
KENANSVILLE, NC 28349 DATE: 07/18/97
COUNTY: DUPLIN SHEET 2 OF 2
3. Begin temporary storage pump —out of the lagoon when the fluid level reaches the
elevation 101.50 as marked by the staff gauge. Stop pump —out when the fluid level
reaches elevation 99.20. This temporary storage, less 25 year / 24 hour storm,
contains 53591 cubic feet or 400861 gallons.
4. The recommended maximum amount to apply per irrigation is one (1) inch and the
recommended maximum application rate is 0.3 inches per hour. Refer to the waste
utilization plan for further details.
5. Keep vegetation on the embankment and areas adjacent to the lagoon mowed
annually. Vegetation should be fertilized as needed to maintain a vigorous stand.
6. Repair any eroded or damaged areas and establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable outlets.
8. Keep a minimum of 25 feet of grass vegetated buffer around waste utilization
fields adjacent to perennial streams. Waste will not be applied in open ditches.
Do not pump within 200 feet of a residence or within 100 feet of a well. Waste shall
be applied in a manner such that waste will not reach other property and public
rights —of —way.
9. The Clean Water Act of 1977 prohibits the discharge of pollutants into waters
of the United States. Waste shall not be discharged into surface waters, drainageways,
or wetlands by either discharge or by over —spraying. The Department of Environment,
Health, and Natural Resources, Division of Environmental Management,
has the responsibility for enforcing this law.
Murphy Family Farms Engineering P.O. Box 759, Rose Hill NC 28458 [phone]

ADDRESS: P.O. BOX 893
KENANSVILLE, NC 28349
COUNTY: DUPLIN
J J_' -- v . ---
CHECKED BY: JST
DATE: 07/18/97
T
Emergency Action Plan - = -
.
Using this outline as guidance, you should develop a specific emergency action plan for your
waste handling system.. This plan will be implemented in the event that wastes from your 5
operation are leaking, overflowing, or running off the site. You should NOT wait until wastes 1
reach surface water or leave your property to consider that you have a problem. You should r
make every effort to ensure that this does not happen. This plan should be available to all
employees at the facility, as accidents, leaks, and breaks could happen at any time. Your
plan should follow this format: c.
1. ' Stop the release of wastes. Depending on the situation, this may or may not be
possible. Suggested responses to problems are listed below:
A. Lagoon overflow —possible solutions are:
add soil to berm to temporarily increase elevation of dam —any permanent
alteration of the dam should be approved by a qualified professional engineer
or qualified technical specialist
pump wastes to field at an acceptable rate
stop all additional flow to the lagoon (waters) --hold waste in house if possible
call a pumping contractor
make sure no surface water is entering lagoon
NOTE: The above listed activities should be started when your lagoon level has exceeded
the temporary storage level
B. Runoff from waste application field —actions include:
immediately stop waste application
create a temporary diversion or berm to contain the waste on the field
incorporate waste to reduce further runoff
C. Leakage from the waste distribution system:
pipes and sprinklers —actions include:
stop recycle (flushing system) pump
stop irrigation pump
close valves to eliminate further discharge
separate pipes to create an air gap and stop flow
flush system, houses, solids separators —actions include:
-- stop recycle (flushing system) pump
— stop irrigation pump
-- make sure no siphon effect has been created
— separate pipes to create an air gap and stop flow
D. Leakage from base or sidewall of lagoon. Often these are seepage as opposed to
flowing leaks —possible action*:
dig a small well or ditch to catch all seepage put in a submersible
pump, and pump back into lagoon
if holes are caused by burrowing animals, trap or remove animals and
fill holes and compact with a clayey soil
other holes maybe likewise temporar�ugged with clay soil
Murphy Family Farms Engineering P.O. Box 759, Rose Hill NC 28458 [phone]

ADDRESS: P.O. BOX 893 v CHECKED BY: JST
KENANSVILLE, NC 28349 DATE: 07/18/97
COUNTY: DUPLIN _ SHEET 2 OF 2 _
*Lagoon problems require the consultation of an individual experienced in the
design and construction of lagoons for permanent repair measures.
2. Assess the extent of the spill and note any obvious damages.
A. Did the waste reach any surface water?
B. Approximately how much was released and for what duration?
C. Any damage noted, such as employee injury, fish kills, or property damage?
3. Contact appropriate agencies.
A. During normal business hours, call your DWQ regional office, at 910-395-3900
after hours, emergency number: 910-733-3942. Your phone call should
include: your name, facility, telephone number, the details of incident from
item 2 above, the exact location of the facility, and the location or direction
of movement of the spill, weather and wind conditions, what corrective
measures have been undertaken, and the seriousness of the situation.
B. If spill leaves, or is likely to leave, property or enters surface waters, call
local emergency management service (EMS) at 910-296-2160.
C. Instruct EMS to contact local Health Department.
D. Contact local Soil and Water Conservation District Natural Resources Conservation
Service office at 910-296-2121 for advice/technical assistance. The
Extension Service can be reached 910--296-2143 for advice/technical assistance.
E. Contact Murphy Family Farms Land and Nutrient Management Department at 910-
289-2111 for advice/technical assistance.
4. Implement procedures as advised by DWQ and technical_ assistance agencies to rectify
the damage, repair the system, and reassess the waste management plan to keep
problems with release of wastes from happening again.
DUPLIN COUNTY COOPERATIVE EXTENSION SERVICE
PO BOX 458, KENANSVILLE, NC 28349
910— 296— 2143
DUPLIN COUNTY SOIL AND WATER CONSERVATION DISTRICT
NATURAL RESOURCES CONSERVATION SERVICE
PO BOX 277, KENANSVILLE, NC 28349
910-296-2121
DUPLIN COUNTY EMERGENCY MANAGEMENT SYSTEM
PO BOX 909, KENANSVILLE, NC 28349
910— 296— 2160
DIVISION OF WATER QUALITY
127 CARDINAL DRIVE EXT
WILMINGTON, NC 28405 — 3845
910— 395— 3900
Murphy Family Farms Engineering P. 0. Box 759, Rose Hill NC 28456 [phone]

Swine Farm Waste Management Odor Control ChedUst
Source Cause BMPs to Minimize odor Site Specific Practices
Farmstead Swine production 2' Vegetative or wooded buffers;
O Recommended best management practices;
t� Ooodludgment and common sense
Animal body surfaces Dirty manure -covered animals Dry floors
Floor surfaces _ Wet manure -covered floors Slotted floors;
t� Waterers located over slotted floors;
O Feeders at high end of solid floors;
❑ Scrape manure buildup from floors;'
0 Underfloor ventilation for drying
Manure collection pits • Urine; W Frequent manure removal by flush, pit recharge,
• Partial microbial decomposition or scrape;
❑ Underfloor ventilation
Ventilation exhaust fans • Volatile gases; Fan maintenance, .
Dust a Efficlent air movement
Indoor surfaces Dust Washdown between groups of animals;
0 Feed additives;
0 Feeder covers;
Er"'Fced delivery downspout extenders to feeder
covers
Flush ranks Agitation of recycled lagoon O Flush tank covers;
liquid while tanks are filling ❑ Extend fill lines to near bottom of tanks with
antl'•slphon vents
Flush alleys # Agitation during wastewater © Underfloor flush whit underfloor
conveyance
Pit recharge points . Agitation of recycled lagoon Extend recharge lines to near bottom of pits
liquid while pits are filling with anti -siphon vents
UA stations • Agitation during sump tank ❑ Sump tank covers
filling and drawdown
Outside drain collection Agitation during wastewater ❑ Box covers
orjunction boxes conveyance
AMOC • November 11, 1996, Page 3

Source Cause BXPs to Minimize Oddr Sites p-ecIrle Practices
End of drainpipes at • Agitation during wastewater Gr Extend discharge point of pipes underneath
lagoon conveyance . lagoon liquid level
Lagoon surfaces • Volatile gas emissions; Proper lagoon liquid cap8city;
• Biological mixing; R'lCortcct lagoon startup procedures;
• Agitation ❑ Minimum surface area -to -volume ratio;
WO'Minimum agitation when,pumping;
❑ Mechanical aeration;
0 Proven biological additives
irrigation sprinkler High pressure agitation;. Irrigate on dry days with little or no wind;
norzies . Wind drift ❑ Minimum recommended operating pressure;
Pump Intake near lagoon liquid surface;
❑ Pump from second -stage lagoon
Storage tank or basin Partial microbial decomposition; ❑ Bottom or midlovel loading;
surface . Mixing while filling; ❑ Tank covers;
• Agitation when emptying CI Basin surface mats ofsollds;
❑ Proven biological additives or oxidants
Scaling basin surface • Partial microbial decomposition; ❑ Extend dralApipe outlets underneath liquid
• Mixing while filling; level;
• Agitation when emptying ❑ Remove settled solids regularly
Manure, slurry or sludge • Agitation when spreading; © Soil Injection ofslurry/sludges;
spreader outlets Volatile gas emissions ❑ Wash residual manure from spreader after use;
❑ Proven biological additives or oxidants
Uncovered manure,
• Volatile gas emissions while
CJ,
Soil Injection of slurry/sludges
slurry or sludge on field
drying
❑
Soil Incorporation within 4g hrs.;
surfaces
❑
Spread in thin uniform layers for rapid drying;
❑
Proven biological additives or oxidants
Dead animals
• Carcass decomposition
W Proper disposit [on ofcarcass es
Dead animal disposal
Carcass decomposition
Cl
Complete covering of carcasses In burial pits;
pigs
p
Proper locatlon/construction ofdisposal pits
Incinerators
Incomplete combustion
❑
Seeundarystock burners
AMOC - November 11, 1996, Page 4

Source Cause BMPJ to Minimlu Odor Site Specific Practices
Standing water around • Improper drainage; Orade and landscape such that water drains
facilities • Microbial decomposition of away from facllftfes
organic matter
Manure tracked onto Poorly maintained access roads Farm access road maintenance
public roads from farm
access
Additional Information :
Available From :
Swine Manure Management ; 0200 Rule/BMP Packet
NCSU, County Extension Center
'Swine Production Farm Potential Odor Sources and Remedies ; EBAE Fact Sheet
NCSU - BAE
Swine Production Facility Manure Management: Pit Recharge - Lagoon Treatment; EBAE 128.88
NCSU-BAE
Swine Production Facility Manure Management: Underfloor Flush - Lagoon Treatment; EBAE 129-88
NCSU - BAE
Lagoon Design and Management for Livestock Manure Treatment and Storage; EBAE 103.83
NCSU - BAE
Calibration of Manure and Wastewater Application Equipmcnt ; EBAE Fact Sheet
NCSU - BAE
Controlling Odors from Swine Buildings; PIN-33
NCSU - Swine Extension
EnAronmental Assurance Program; NPPC Manual
NC Pork Producers Assoc
Options for Managing Odor ; a report from the Swine Odor Task Force
NCSU Agri Communications
Nuisance Concerns In Animal Manure Management: Odors and Files ; PRO107,1995 Conference Proceedings
Florida Cooperativc Extension
AMOC • November 1 J, 1996, Page 5

Insect Control Checklist for Animal Operations
Source Cause BMPs to Control Insects . Site Specific Practices
suf clently to remove accumulated solids
mutters as designed.
2 Remove bridging of accumulated solids at
from
discharge
Lagoons and Pits Crusted Solids Maintain lagoons, settling basins and pits where
pest breeding Is apparent to minimize the
crusting of solids to a depth of no more than 6 -
S Inches over more than 30% of surface.
Excessive Vegetative Decaying vegetation SKMaIntaln vegetative control along banks of
Growth lagoons and other Impoundments to prevent
accumulation of decaying vegetative matter
along waters edge on Impoundment's perimeter.
ms
ge 2' Design, operate and maintain feed systems (e.g.,
bunkers and troughs) to minimize the
accumulation ordecaying wastage,
CK Clean up spillage on a routine basis (a.g., 7.10
day interval during summer, I5-30 day Interval
Feed Storage Accumulations of feed residues ts1 Reduce moisture accumulation witfiln and
around Immediate perimeter of feed storage
areas by Insuring drainage away from site
and/or providing adequate containment (e;g„
covered bin for brewer's grain and similar high
moisture grain products),
O Inspect for and remove or break up accumulated
solids In filter strips around feed storage as
needed,
AM1C • Novembtr 11, 1996, Page I

Source Cause BMI s to Control Insects. Site Specific Practices
Animal Holding Areas Accumulations of animal wastes ❑ Eliminate low areas that trap moisture along
and feed wastage fences and other locations where waste
accumulates and disturbance by animals Is
minimal,
❑ Maintain fence rows and filter strips around
animal holding areas to minimize
accumulations of wastes (i.e., inspect for and
remove or break up accumulated solids_ as
needed).
Dry Manure Handling Accumulations oranimal wastes ❑ Remove spillage on a routine basis (e.g., 7. 10
Systems day Interval during summer; 15.30 day Interval
during winter) where manure Is loaded for land
application or disposal.
.❑ Provide for adequate drainage around manure
stockpiles.
❑ Inspect far and remove or break up accumulated
wastes in filter strips around stockpiles and
manure handling areas as needed.
For more information contact the Cooperative Extension Service, Department of Entomology, Box 7613, North Carolina State University,
Raleigh, NC, 27695.761'3. I '
AMIC -November 11, 1996, Page 2

Mortality Management Methods
(check which method(s) are being implemented)
❑ Burial three feet beneath the surface of the ground within 24 hours after
knowledge of the death. The burial must be at least 300 feet from any flowing
stream or public body of water.
Q� Renderinp�a't.-a' rendering plant licensed under G_S. 106-168.7
Sd S AT- SrrE re--F- Pe z A"1"At- 6nujEC' OAJ $Y 7P7--v-K
❑ Complete incineration
❑ In the case of dead poultry only, placing in a disposal pit of a size and design
approved by the Department of Agriculture
❑ Any method which in the professional opinion of the State Veterinarian would
make possible the salvage of part of a dead animal's value without endangering
human or animal health. (Written approval of the State Veterinarian must be --
attached)
December 19, 1996

Producer_ Lam,.-k
I
Location: HU)`i v 1 AIC LD— V.r•
Telephone: a q - ppq $
Type Operation: v3c_ c, - je.G a ee V—
Number of Animals: QC�
(Design Capacity)
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface and/or groundwater. The plant nutrients in the animal waste should
be used to reduce the amount of commercial fertilizer required for the crops in the fields
where the waste is to be applied. This waste utilization plan uses nitrogen as the limiting
nutrient. Waste should be analyzed before each application cycle_ Annual soil tests are
strongly encouraged so that all plant nutrients can be balanced for realistic yields of the
crop to be grown.
Several factors are important in implementing your waste utilization plan in order to
maximize the femilizer value of the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply more nitrogen than the crop.,
can utilize. Soil types are important as they have different infiltration rates, leaching
potentials, cation exchange capacities, and available water holding capacities. Normally
waste shall not be applied to land eroding at greater than 5 tons per acre per year_ With
special precautions, waste may be applied to land eroding at up to 10 tons per acre per
year. Do not apply waste on saturated soils, when it is raining, or when the surface is
frozen Either of these conditions may resuk in runoff to surface waters which is not
allowed under DEM regulations. Wind conditions should also be considered to avoid drift
and downwind odor problems. To maximize the value of nutrients for crop production
and to reduce the potential for pollution, the waste should be applied to a growing crop or
applied to bare ground not more than 30 days prior to planting. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. Acreage requirements should be based on the waste analysis
report from your waste management facility. Attached you will find information on
proper sampling techniques, preparation, and transfer of waste samples to the lab for
analvsis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A
NCAC 2H.0217 adopted by the Environmental Management Commission_

..•w......�.......... ^;wG';'G:::::::tin':.:."�v�'::::�:�vt..,....,.............'v:G.-a:..�'Y::::an::+`��.......w........wr�..`V::,.r..::`.:e:::::-t,:.it�i4i<:.i2:.:�:`w.}': <s..�..........i...�-...i.
Amount of Waste Produced Per Yearlgallons `tons, etch
.$ ns
boo animals X J) fin-waste/animaYyear =1 O � (efg')waste/year.
Amount of Plant Available Nitrogen (PAN) Produced Per Year
Z6 animals X .q%s. PAN/animaVyear = dl_ y g lbs. PAN/year. (PAN from N. C. Tech.
Guide Std. 633)
y; ,.A A -
Applying the above amount of waste is a big job. You should plan time and have
appropriate equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on the crop to be grown
and surface application:
Table I: ACRES OWNED BY PRODUCER
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
m No. Type Per Ac. * Utilized Application
Total ri E . 30a 5
x This N is from animal waste only. If nutrients from other sources such as commercial
fertilizer are applied, they must be accounted far. N must be based on realistic yield
ectatian.
NOTE. The applicator is cautioned that P and K maybe over applied while meeting the N
requirementL Beginning in 1996 the Coastal Zone Management Ad will require farmers in
some eastern counties ofNorth Carolina to have a nutrient management plan that addresses
all nutrients. This plan only addresses Nitrogen.

,,,,,.,,.,.,,....,., :,:«::;:-w,.w..:»,;�Mr::�.xx::tie:;•,.::a:w�,,;;:::�«::::::�,::�zx ,. �zti;:.<
Table 2: ACRES WTTS AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowner must be attached)
(Required only if operator does not awn
adequate land [see Required Specification 2])
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
* See footnore for Table].
Totals from above Tables
Acres Lbs. N
Utdized
Table 1
Table 2
Total
Amount of
Surplus okD
r.0
eficit
3oa5
MO
3oQG
oduced
! a y $
-]
NOTE. The Waste Utilization Plan must contain provisions for periodic land
application of sludge at agronomic rates The sludge will be nutrient rich and will
require precautionary measures to prevent over application of nutrients or -other
elements
3

See attached map showing the fields to be used for the utilization of waste water.
Application of Waste by Irrigation
Field Soil Type Crop Application Application
No. Rate In/Hr Amount Urt-
dA►-.Bero, q .cam
THIS TAWE IS NOT NEMM IF WASTE IS NOT BEING APPLIED BY IRRIGATION, HOWEVER A SIMILAR TABIE WILL
BE QED FOR DRY LITIER OR SLURRY.
Your faciRy is designed £or4RIdays of temporary storage and the temporary storage
must be removed on the average of once everyCo MONTHS. In no imstance should
the vohme of waste being stored in your structure exceed Elevation osee oo n AC S �►-�
Call the local Natural Resources Conservation Service (formerly Soil Conservation
Service) or Soil and Water Conservation District office after you receive the waste
analysis report for assistance in determining the amount per acre to apply and the proper
application rate prior to applying the waste.
4

^S, Yam; - - - .h ..k. ,."^'^ _
::
,+....,�._w..,,...,,..»�4,..,......::�:::....�.—�--„�.�ct.....ti`000�:i:;A<+�::.a:"�..w�rr.M..v:�ca'.\:i`.:..................�,..,.,,....,..�..�..,,...+,...,...,,...,.....,,..va...............w;..K .....,...... �-':::
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by nmof� drift, manmade
conveyances, direct application, or direct discharge during operation or land
application. Any discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the producer either owns or has
an agreement for use of adequate land on which to properly apply the waste. If the
producer does not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a reasonable
proximity, allowing him/her the use of the land for waste application. It is the
responsibility of the owner of the facility to secure an update of the Waste Utilization
Plan when there is a change in the operation, increase in the number of animals,
method of utilization, or available land_
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic
crop _yields based on soil type, available moisture, historical data, climatic conditions,
and level of management, unless there are regulations that restrict the rate of
application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre per year.
Waste may be applied to land that is eroding at 5 or more tons, but less than 10 tons
per acre per year providing grass filter strips are installed where runoff leaves the field
(See FOTG Standard 393 - Filter Strip).
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it wigl be sod
incorporated on conventionally tilled cropland. When applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not
occur during a season prone to flooding. (See `Weather and Climate in North
Carolina" for guidance.)
7_ Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
runoff does not occur offske or to surface waters and in a method which does not
cause drift from the site during application. No ponding should occur in order to
control odor or flies_
S_ Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.

n
,:..n., vim;: � :..:.............:.:>
REQUIRED SPECIFICATIONS
(continued)
9. Animal waste shall be applied on actively growing crops in such a manner that the
crop is not covered with waste to a depth that would inhibit growth. The potential for
salt damage from animal waste should also be considered.
10, Waste nutrients shall not be applied in fall or winter for spring planted crops on sods
with a high potential for leaching. Waste nutrient loading rates on these sons should
be held to a minimum and a suitable winter cover crop planted to take up released
nutrients. Waste shall not be applied more than 30 days prior to planting of the crop
or forages breaking dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the
following: The outer perimeter of the land area onto which waste is applied from a
lagoon that is a component of a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other than an irrigation
ditch or canal Animal waste other than swine waste from facilities sited on or after
October 1, 1995), shall not be applied closer than 25 feet to perennial waters. (See
Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14_ Waste shall be applied in a manner not to reach other property and public right-of-
ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands
by a discharge or by over -spraying. Animal waste may be applied to prior converted
wetlands provided they have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
15. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc.,
shall not be discharged into the animal waste management system
ri

UX
`:.::..:... ..::....:......:....,
REQUIRED SPECIFICATIONS
(continued)
18. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks, and spills. A regular maintenance checklist should
be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops for
direct human consumption However, if animal waste is used on crops for direct
human consumption it should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall
be managed to maintain the liquid level between the markers. A marker will be
required to mark the maxi mum storage volume for waste storage ponds.
22. Waste shall be tested within 69 days of utilization and soil shall be tested at least
annually at crop sites where waste products are applied. Nitrogen shall be the rate-.
determining element. Zmc and copper levels in the soils shall be monitored and
alternative crop sizes shall be used when these metals approach excessive levels. pH
shall be adjusted for optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry waste application records
shall be maintained for three (3) years. Waste application records for all other waste
shall be maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina regulations.

WASTE UTILIZATION PLAN AGREEMENT
Name of Fa m:
Owner, Mmwger Agreement
I (we) understand and will foltow and implement the specification and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. I (we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new facifities will require a new
certification to be submitted to the Division of Environment Management (DEM) before
the new animals are stocked. I (we) also understand that there nmst be no discharge of
animal waste from this system to surface wasters of the state from a storm event less
severe than the 25-year, 24-hour storm. The approved plan will be filed on -site at the
farm office and at the office of the local Soil and Water Conservation District and will be
available for review by DEM upon request.
Name of Facility Owner a. r' -
(Please print) C�
Signature: yam(
Date: /
Name of Manager(If different from owner):
Signature:
Date:
Name of Technical Specialist: (Please print) I!!�a O e-5 � -
Affiliation: l" l , ,- \I
Address (Agency): da,e q
a-Fz� 5
sign
9

�i� r. '� r '� � 4 i:!'.;',!'fiT -,. r , •�� r`,�� �� � � trt� �:� rj' :t' y�j',.'i1 •tt5y�
1a '� � ; � ��j i�-! �y ' I �y rAaf- � �• lit f' � .l• � ;r •�
l•. I :J 1 "`�1' ,� 't.1 �• • '!j• �h ,'. � � i'}!'-�' ���'• r f 1j •17r , = '�.,^ y, '1�. t '
I�� J TT��/[�� �•jt .�, ,.�i' r '!.{• '+ fir• ,jis �cfri' ti �k .t � ,7► -�. )+. ,, �l)`
AL
!aa . ^���� �I t �� � ' r . ''}. �. ,�, 1�. t n . ;',.�►'��`' .`j ',.' 'r'f r�'�'' -'A � Ai' ••+�
IL
V�. t •! Lrr 'f n: i t'%•'•' ' , 1
'h � t f 'I .""r,r 'l i+�,''.Y' :r•'. � ,. Ej! '�1 _ E 1 ,• , f i 11.71-•` ' � ': _ .� `�,. �` .
", i ll0 1 � J ,i�1 'r�s i 1'`i * <r. .tl fi ,.I.fll r �I� ' r I� r';��C r •7�,C /�{l, �,
fir, la • �,�'� r !, o '.; `•
' '�:.,'. � i i •- [/► •if.T;u.. �r ri.: � 1. �1., _4
��'1 1 +1�- `.1 .�, .•� �1.}'e .� '�'i+:' ,� '1 '!' y':' �,., '1'• i,'S�:��•5 l,'•�f � . ;. :Y;f :�
cry
i 1 �;1� , i' ''<; •_a': ' {',,' ,
y •,q'ry� � :+� '%k•. �;�'.���.,C.'r` ,�� J�, •� �,''' j i '�i.l• i
'{�'� f+, t,�y`L�; �; - (� 73 .,�..,'�?�� ,,4?�,'.• 3 i; t� i :;t, �`r o- i� � ;"'J,t:, y '3•i ' i '•; 1 F� •
ti\.".•,r''S � ii,c rt��r�,� � jj}�','y{��y7j�a• 'j:, 1 �'� � -/ '� � .. t' ` •S, {� � /J�
•1 '�: / ;ii; ti<�'+ ,+ !' • a S j i tiyC.{.f ri�l5' '•1lo
9'�•
ilr;1 .[ •It. f . l ` w �y '� f ^-T-ter , ` 4'�n.a� `•11 . d{ . , '' �i �.
V��"t' S: .�� r+S �5r 'i1, f' fe. •y 1 1 1 1j, r' 5 .'}3.' / ,' `. 1. ' {•
it's. �{'.J� :I- � -r`,.'�i 1. •J.•, 1 1,' 'Slf-.�.;: fg1J'1/1} �.. 1';i. /,: �,' �'1:�,+, - <r,:'= ,,. �.�{ A ..•• ,!,
_ fir ",t: 1 � �%'f •:1'.' !•.� ;�� { - ,� ��;f'-'.�''i'
.i ,,x•hr •l 5'
'7r i 1,1,1. \� �' r ' `,t4 !� F 1 :CI i``�1::�F3'��•�• •y. �'�' [r r+ 4 1•
410
�.,'',V'�17. 1�- '!' {• } 3' .Z7 •J'.i j/y��i Fr111 t i3''.' .�• t
.�'tl t '{',I �.t' "•r'li.F {il '�1 �• 'IAA / , 1,} !' '
'�f ,� 1 �� �. a ..i"1 '.' •Y•. y'y A 1 •)•:*�1 ��'/V ffll rr *J •.[�• '
o.
x ' 1' ti a , `f}fie �,rt"t .r 3 .. + ,. 1,• '•.:.
' :1''.'. ?:..�'. �• ,�, ti,it r ( t :.,pz ,;� - f, t r. �';, 'ii', •1 .b 't � , ,{�', i°�'^• +�

.4. rrl r' V. ,. 4�, :r t'f•:.-:a:✓:'rrJi '1 •r. 'r. r.e• t
'Y.<! I:.ar ►1 '+` ai, ., ►'' rt.:L. it 1
Gi I !•,, 11+•��`r •), .,�'; !r v{ l', '+ 'v r,. I,. •4..,^ it t y yr 1.. rJ, //.� ff rl,•', !.
++: ' l l:+a. 1 i r'. 'r :r 1 'I r''r• r+ ,.:•+. / . fi J' 1,1• �'♦ #+ ' i+•
ri... �r, .r; y` •1 �:y: '.r' Y�1.f, eJ . �r rlC !'}� (;.'.•''r.. :. .r , s rf � i � r � ,rr{r, t �+
f'• it:',R •}' 11'{ +l.I'di - .r �'�`� ' J 'r' i': •'1.1 ,'''��r ,•'r', rr, • �'":::. f ;,.: 1rF J Y { k'
•F fy• Ie'�. •t,, 'i l� �l,! r,r 'vf %1 !'7S}• 1•. +'S':r •i• rl" �i' :•r''J, '+il i-ft'`�y•,1'':. r1+�J',r li 1� r�,rill
�f. ,.r, r•.f„ i' i,.�: r$.:4 'r,t i' t,!' •'t �. .'S' �� '•!f' ,y.A' . �^ t,'�:.`.{ f}T
1ti Y' 1 Ell . r vtr' f r:j r: ;:. /,",• 1 i
',S ., .St Ill., 'i• :�;k'. .�'� j Slr..
!xr ��1�: rfd� i t'•
ts' i�� '�t. ;i% :',�,•"' .,r: r',S:r'r'Ir•t:, ,lf;:i'r'•d: �'' 1 1•;,• '•'+i�'.t/.' �je ,rf' �.",.4:
.) it '.11I. 7'+,Sl ,.1. .r• �+�l .,r !,�:: i{, ,, :,•)!t. 'ryrt,r!,�•• '1:'• i. ).�,, ,�'tr�'. �r '.I (lTd. �,•,i
. 7: •iS:w•f _`��:T:; stir !rJ�rl�j,°�',}}t _J: •V. rl.. '�'� :�
�'� li lla'I''ffi Tt.. .4�iY,.J�F•: �I� �S,n .'I ''7'•Fy`•, :'1�• •'r; t15 J. •+'•
J1•.�, a. ! J, a r., r' !. r [ •ti w
>•f 'r`: .;. 1: lr r`L, { .f:d �l•.r -, •,r + 'i '�� i
TA�yI// a�J. .J.rl� .r:,e. r 1' +A -f� ' 1. .1. 1, r5• rr, 'i''r'•I'`' f! '� �H,_�`T� r
y,,,k i+`• ::� Yl�a!'r••+ ' y : f n'r,J! . ,.i!.1 r • ,+': , 1} Ir. 'v t r fl�viA,
" 7 7 ff:' 7'i+ 4'� 'I,J.1, 'r t ,1 : '',;1,?t•• i':•a :,I ,r r + ,} 1•i, Y x vt 7 s �•!aj ,i' ��
; ,ter r• I frl'XL" i! rh', �a' f r �'S :,ft:fi p r '' •'• r r r i� r� �'o±� ��yW%,r�r
'1 r3 a1. 451411 ,,4� rot Jj l j Ff f f r r r • ,
.il' .;.,t!.1•,r� tr ! t�T+,IJ�,F �`f', f'7' I f r ':'fir 1. +/ 1 ,��: �• •v
r 1 4 (JJn f.jil t+ t +• + 1 �,;.Sr::'�•:r 1 7 , 11,,' f �� 1 }
i.,lv; +1 f• !rf Oil
p,� �.k .7•, ,�'rr rh,,SS ,'+ I rrtt s I' 4f ,yF I
'y r+ i I-'i f • •: I' �j •�•'7•r `''. rI• r '•. 1r r sY+. 'k, + 1.,; ii !
Rh.:r.ti.,�•t, .,I sr. ..t;�.: 'YIf
::j::l;}...r a,• 'a 4; 1•y�'�(•ir's}y•1! •.ain,. i. j.,, r+;, Y: ra+:• i... {{Fp •F': ,,r .t.:4..'rc :,•. .Zit+l
e: L i ` L �.� +'.•�r�!.'. y /I I'r,'.t,r' a' jr:• } . r• °�/ J'''' : I 4 �� ,J
�'•'-l.:I,r !I•�I�iy'!�'f.: f';'SJ :i1'�IiJri.'irT 1:'1 •i G, "jl�. .•J's, ,1+' i'hi ��5�./:' :�`fyti'�: ,'�,,� k,.f,./;, �1.J •►:�,. rJ.r^f J,.�+l�r �..�r,�, �, '. y: ('!7� �+}�•t^!+ �:.i�•'�� ���.� .+l-' �r�• �
?'rSF'7rJ: .,Yi. �9, t- •�a Y, :'+. rf j:Y.:• +.' •.3.rra�.�.x� .�!i •�
rr :Y f. ,ygf:r ra: '.4: '•,F�;i �'�lir..r• r r .,1 ..l ,r';5;•., !F' ..l r,•1:.r +,t..,rn5.:�.•
,'"F .r j � }' � f r •'r ' '.F::1 u , a.� h-
••!•',., {. r•i •r •1: 'r •` 1, !'• + y •'"J � ',Y 1:`a. S r t'~ • •�il}'. 'i'i j.•1 +• r.f ''T�JY,. �;i
:.ir'r,[x1+�;Nt:i�r` :�ti ): '�ii:•'IJ'r � ;• � 1• l,+ 'f' '.Sr'• ;r ,..• >f :'. •` Jrv�••'yrl33.� �ihrry t+': .L,111"1
''.i 't ; '� j,' ••r.`r' 1. +(ti? : { i. .rr{ : r , R'•, Y o r'. .? ,\'. �.
:irr�r ^,kS.� t�.f, � � r,r.+r. •. •--_! '1 '�'i�., "�•�.. '��I'�t�r.�r, +a',�:yr t �• f.;,:
• .r"
�' �IAif1�.t���i +'I";' ��'� ,ht!,' +r+c..r.,.G',,:fi 2 rr,i�r.• y f� r
r
,!r � r� •f + Y+ r � f �- ri' '.� '.ry .``Sr+?�Sf V,r :+'n"Y
}, -r+ J 3r' tf 7 r 11 r,�� •fr�
�' ` ''�rr't "'ly: �I 1'!55 r • II � 1Ji �4'.. }G� '1:iS ��R,I:�`y'Ir'tTM
t.. � •err:' }Li r '� s uk.'t r� Y�Jt1� t••i�ir` r "'�1
, ;�t•, �,;T• --' sags tr..�
+1v +1ff..�" .��+,. G'.. I �a:`i•'ti:r Vi•�1,,,. .r .r JrPIT
r, .�(.• Si. •l� . � .l�/, �-.5.-+'S.fr,xi .r .iii. C/• .�% ,
i-ff','� •ry'!. ,, S L '� %'2..i5 . rl,t, r• :• .i1 .I� �. i./; +'a' ���,� • { f.�if}:i. �,,�r'. `✓t
.::��,�r, rf, r. al,..rf. 1 . r,.fl �f.•y�+ .•S,r.
(r';T',t'r•;. r�' %�y r,gyl„�;lr ri, rf �/.•C�i. 7r�y qr.:�1 '1.J1'r •'. jJ�'r:r
rl!;..}�,.jikJ•;.C'�i•:ity.�,/�rJ,.,rf ` \ � i'';:;�,�:a',1'S..r�I•►r�1�1•,'s•1:,'j•�r,•J,;
;.p{�{L��j �` ,.`a'Sv::��:)1�. �r r �i�!•'�' •�:•:r,,;..14"{if":+•rj:'-%i'•'
Vr• r':•r'' r: •f' %' �'r: 'I::;•rJ}�ril�yylIl-,•; •1. �,f
rS„; �J +''r^•J:l�r,'11: rywS4r. •irrj�f.1 fe ,.�7f _•y„Tf
f{,:•1• .,1r,f:.3' _ ;f;. .f'z'= SI':3��F ^•f•.•::'V:kr
is ;'f.J • %'�'1ri +iJ,_� ,ti .Yj�' .Si �; f * !^%i�_'�.S�h�.5,;1 +.i:,q.r .�
_f�;J 'rvls<.:r.rt..y, �� ��,c:.r.,,`,,�.'r.�irH'�: .�.>.•.h�• s:
7, I. �'► +' .,.n r,;s } '� r/ • �:Ir.; �'1�fr^:l•�+:'r G;= ,f e, f'� .�]r'�
. •1 !. � •4 . i, J Y
•'��`,ftt 11'f•`s1.. )'�%�' ; :Ir !'t.�y%t :'�; �,'. i-•1:?'v'%j�l,;;l•IJ•�+r•,i�r.`�I'f1�J.: •f
itr .l,J•j'.�'t l;:lr: i+• j „Cl7i„rr•1i.
1.'('tS .: .r1�� .�9ri�-�.r.l. ,..T. i.ri %..,1 ,•L.1%.�J.f::.'C��
ply
'at;ry,, �ri...'iy. r'•j r ;6v" �1,:v-d"rf° \l't�
•rl, '.1 rtG�r• �I i
Sr ,I'jf!"f }•�41 •fir j%�I[�r'r �r •�'i���,Sy &rAri�l If
41
r r Il +rf•Y,, `,a `.�., .: fir •>r .IA ii
��!^y]]]�••1`'S li r�, 1.n .tJ, �....,r�:f ''j ,y,�%�yt;
r fir+r •
.i r� aI f ;f"G: J. /+, �lr rr 's•w n`�Itl .•.'V=
J) 1.T.�vr+j�� �`IlYyyyy s♦
21
lot
� �• " • r ' I1'Ji y J ? lr ! 1 r '.1t4r�'.J.SiiY• A�'ai �. '!`
tl 4 r ,ik'1•'grLr tlJ�trky .%.^• ,S_ .�� .X�'�;4.T.is^'iy.f:'•:,'•(i'
tI`{` rr Y �f J , l�f��[•�'�J�!+� tr'iL jY �J 'rS��-jI

Londu+ri.er/opcfalor Name:
Address:
Telepliorle:
McW SPecikations
IRRIGATION SYSTC, M DESIGN VAIM11+,`FERS
�r L $r...rt4, tit ors
Li
NG�
aq i6— o0. 4
County: � 1"
I'aIF !?g/9 7 - -
EXIUDIT D•I
�IeWI
Number
Approximate
rrlaehuvn�
!!stable She
offlel42
(acres)
Soll Type
Stop*
(Ye)
(s)
MuxlnI11114
Application
Rnl*�
(hdhr
MadinU23)
Application
per Irrirottop
[jelc3
(Inches)
`
>
Conuuw1ts
N 3
Gam
1Cro
/
!
. SG
+
^-.,,41 i�� V�lie_ fir' IS
f,� %0 flit ANT
l
Isce nitocllcd 1110P.
1Tolal field acreage minus required buffer areas.
j�efer to N. C. hrigalion Guide, field O(Yica Technical Chide, Section fl C. AmmUl npplicatiou must not exceed the agronomic rates for (lie soil and crap used.
1
MRCS, NC
j1NA WSWRT SllW434 " JUNE, 1996
L1fi1-W3�-YhiH��
t3AI3331i

Exiflwr D.2
TARP 2 - Tr-lypillIg 11-1.1 ling Gun Settings
hiaicc, hloticl aniq'[ypc or Equipment: A'QT /%.aev-we.1 C 17 ,., Ge��s �P M�ctwi 3L •G
Field Nol
slid
Il •drant Not
Travel
Sl>eed
(IV111in)
Application
Rate
(iidhQ
TRAVEL LANE
Efrcctive Efficclive
width (D) Lcn 11t 0)
Wetted
Diameter
(rect)
EQUIPMENT SETTING
NOule Opersting Opera�g
Diameter Pressure pressure Arc
0 Gun ()SQ Pancrr,3
CoplrnenLs
1d
�-
. fr
4�0
OD
�Q
a�rG�
q
1 a 6
Bo
a. 6"l
1 ra
Be)
*� I�
�a
All
o
I ,1
9
J•b
I•I
Pr A
!See 0110c110 mar.
2S11aw separate enlries for eacjl hydrant jocalion in each licld.
3Usc j11c following abbreviations for varlous are paltems; F (Rill circle), TQ (three quarters),'IT (Iwo (lords), It (half circle), T (ane third), Q (one quarter).
May pjso use degrees of arc.
MRCS, NC
JUNE, 1996

IWIIBIT D-3
Salill Set ki-101011 Gm, Scttlugs
lllnice, Model and Type of Equipment:
rkld Hui wetted Ilydranl Spucing (ft)
and Number or Dinnicler Along Dehvicen
iAlle Nut ll drurits (feet PI Pelinc Pi pluses
OPERATING PARAMETERS
Application Nozzle Operuling Operating
Ratc Municter Pressure 'Tlrnc
(iulltir Inches @ Gun (}sl) I[ druid hr
Coutnicnls
ISec allached map.
?Sow separate cnlries for each pipeline wilii hydrants in cacti field.
NRCS, NC
JUNE, 1996

TABLE 4 - Erriga(ion Syslcti► Sl)cclOcatioiis
Traveling
Irrk gallon Gud
Solid Se;
Irrl anon
1!lotiv Rate of Sprinkler (glue)
perating Pressure at Pump (psi)
6
Design Precipitation #tote (In/trr)
Hose Length (feel)
S 7�
xxxxxxxx
Type o(Speed Compensation -
Pump Type (PTO, Engine, Electric)
M i L1es��n
xxxxxxXX
Pump Power Requirement (hp)
TABLE S - Thrust Block Specifictt(ionsI
Designer innrovldc thrust block detalls on se nrate sheet.
LOCATION
TIMUST 13LOCIC
AREA s . M
900 Bend
.69
Dead End
. 4
Tee
. 3
ISce USDA -MRCS Field Office Technical Gulde, Seclion IV, Praclice Code 430-pD.
Ma 11131.17 DA
NRCS, NC
RUNE, 1996

FXIITBIT D-5
Pompany:
Address: Lx" 3,oX "7 - - -�eSa- f�rl�.',C. 48u
REQVIREt) PQCt)4jEMTATJ0N
llie following details of design and moteriols must accompany all irrigation designs:
I A scale drawing of Ilse proposed irrigation system which includes hydrant locations, travel lanes, pipeline routes, Ilultst block locations and buffer areas where applicable.
2, Assumptions and computations for detenniuing total dynamic head and horsepower requirements.
3, Computations used to deternine all mainline and lateral pipe sizes.
q. Sources and/or calculations used for determining application rates.
5. Computations used to determine the size of thrust blacks and illuslrsmiwts of'tdl Ihntst block configurations required in the system.
6. Manufacturer's specifications for the irrigation pump, Iraveler and sprinkler(s).
7. Manufacturer's spccirications for Iltc irrigation pipe and/u� USDA -MRCS slandurd for lrriballon Walcr Couveynnce,
N.C. ):'icld OQicc TeCIRIi{al Guide, Scclion IV, Pruclice Code 130-DD.
B. The infornnalion lequired by this furor ure the minimum requirements. Il is the responsibility of the designer to consider all relevant faclors at a particular site and address them as
appropriate.
9, Irrigation pipes should hol be installed in lagoon or storage pond embankments without the approval of the designer.
N qTp: A buffer strip S'b feet wide or wider must be maintained belween the limits of Ilse irrigation syslem and all perennial
streams and surface waters per NC Slatutes,
NRCS, NC
FUNF-, 1996

9661 'aNnf
ON 'SOUN
1
I
✓
'yf , n/n e s 1''�""y
D J'r" J, JV"
Q l o-:� �z� Y rr
r
s-7/-'xw )w
"�� .. `ts^ I Y"tTF,-a
s
rnPu-
'l/'215••, ty7•t� iV� �v "
11 '���p
- f Jabs
1s,ro wJy rJ
R}vn
r�
�'?'Yr" -�w'.�,,,,,
1�"d ��.•v�p
� :�r
�., f, � a� ...u�
s�! `7 s J'ir^o�
�+�+tiw
YJ ,� J f v! Vr / • v -7�/,I
v
-��
! ryy,r ,rY i
"�(•'n I
�� C
-7t 9 97-7wTV
�v�.f-
T 1.1 _ IW '4", � f �s'7w
Vr C• ;�O
J�
N..IhWJ w
'� J�� �v�r�p �r / ��%�
�� �
! 1 � /' ,r j�vwy�� L✓� '�i �,ti/
/y
"7`!,��j'o
I,%�'
7Y v Qpy 7Jly 7/ /C v,
�� r 7 nf� {� 1.,q
is-ar f114. vl
r.7
Vo �J1
`y_f%�'`
wqv
70,
cw
\/.Y{�.Y !//7 ��r►e arm / ��
("i0 27v7 / to � / � � �vp
`I ��
p r
T s ,' y
'Ittoutdtubo IIn jo amuuolutom juptUai pun uolltrZualutA%'ttA%op-ltttts 'tltt•lsnls rn ttnttS sNnpa A apnla«l
aattddus/MuSaSap 0111 a) Itlatutnuoa ISMII Iaarys 1ntituIS n uo 10 AtotaR pnptJtnfd muds -.1tt1 u1 1110II S oil Jo 11011nixto atll-g!nsa(I
U01;UJOdp IIIaISAS 1101JU3l.f.l1 J0 aA1jI1A.I11N
9-0 jimag

t
M
T
r
-
w
j
�
a

I
CA ~ a
I
M
M
�k
r
I
h
`h
n
M
t
Y
3
e\
in
n
AI
nIQ

M
p
0

n-w a fh -oo Is rr Y, Ito A,4
&
Pon
Ivy. 4;
to
gf�-,5i,
two
04 , at
tot
md"
Ito
of f
tot?
It a
Jrj,0
40
9.14"
r4
"'Joy I j :.'., , I Av,
t
o'1llali
0 16
J�j ;IF �* I ') w % ;
Sim yi I., - I , I; I I f -4.
.1 1 t ork ,
1. .4.
to 0 �111� All op
;orpro A
r.OPP
'J,�•• of
1r,
4 to
T,
141.
of
It
),to
to to".
to,
or
ft to.
jot o"op 84, 4 .1
PY
60
Opp
114. .0
mooso
o ot"
, PAf
to If 'N
I
to
un 'I to I •a,
I

02/12/97 20:15 -a 9103431452 PRICE POWER 0_.
'Performance PPPCF POM 1 LLSis Group
19ns Cam MAYNE RD
wH. Na 2M(8101�PUMnim
A
METERS FEET MODEL36h6
}, tNy �.�s . i ; .. .i..-.f ,.. 11/zx2-6H
350ORPMODPxTEFC
GROUP —S'•
50 180j�
Sim. Jo
VVV
80
jet
40
0 00 - 20 40 - 60J 80 100 120 140 GPM
0 10 20 30 M3/h
CAPACITY
Pei) G t
METERS FEET
30C
80
25C
0
00
20C
C)
2
.
cc
z
15C
0
40
�
O100
20
50
0`
1 s
RPM 11
.
MEMN
M
rr�K��
�1L'1•PPPPPPPPPP�I�'���..��`1���,�
, �
��
=Mh@!
..qF
IN
M
M;f=
'
wow
MIM
11MIMIM
00 50 100 150 200 250 300 GPM
fi T
0 10 20 30 40 50 60 70 W/h
vw Gfil
(� 15116
too 6?i'
1 5/g

JUL—Zl-97 10:30 Pm EASTERN- AGR1->SYSTEMS 1 iu293788`_•'
.AB1 AQUAREEL
P - 02
Long life - Low Cost - Low .Labor - "Even. Distribution - Low Pressure
SIMPLF (,tPERATION
11 couldn't bo caOcr. The Aquareel is simply connected to it',
anchor and towed acnh,,(lie field la_Yinh cnri iCs hose:. Tihc
spray arras are unfolded and when pumping comniencei a
airnple dri,r nutlturristn is uutotnatically uctivalcxi. The
Aquarccl them pull• itself back. applyine- a gentle acid even.
application, picking up and storing its hose as it -0c . When
the run is finished all lhc= hose ii neatly wound onto the
machine and iI is ready to Ix moved to UN next ix)tiition rrn
dr[ty. hme er code to mcss with.
Anxa f,,>GirAjrure�'lnra�++,rrufirrrr
41 FLEXIBuxl'Y: If the machine is towed out and the he+.c
N laid in a g milc antic the machine will follox this
curve when pulling, back in. No problem with short run,
just pall out the machine as far tls ro-quirecl 'IZic spci ial
'harrow brtil:c' enahics the Aquareel ru be used tut] -JoP05
and cicmihill.
• LOW' ( OPF_1t4' 7NC PR.F5SLIRE.-11io efficient constant
torque drive syslem al lows the Aqutirecl to wtirk set
pressures as low us 3(3 psi. Soft rubber nozAcs will pets.
solids tip ro 11-1".
• I.0'*V A1AINM1ANCF:: Gaicani/cd for long life the
Atluarccl rnachinea are Simple to maintain, orliv w3utine
gt-NOilig is re(luired.
* ADJUSTABLE APPl A:ATIC)N: Nl;ichine slx cci,. art'
altered by adjusting the drive nozzle angles. ;1 wide
range of spetds bc'int; possihlc. A vCry quick and easy
operation.
• LOW GROIIND PRESIS 1i.C: wide pR)filc tire:,. cnsur.
low ground pressurn..
Idewnl for the: lion or Duiry Farmer, the Aqutrvei i; probubly
the neatr,t wlu[ion Irl waste water di.p;Kal l,.ailuh4- can the
nLuket (oday. aytl:lrUT",cornfKici sl2e and mmplc uper::tion
dis"uiSri a Ilii'll PCrt'al'liraucr utuchinc of , rea! , ercatihl% arld
excelicrit rclluMliiy. Compared to other Ny*>teri� on the
tnark0l.. Aquarc-1 c risufei that Shin') is uppli�:d al the correct
fate, at the right time with a mininnini of Celia! and nperuior
input, reliably, ct wdsteri0y :,.nil co'cinely Cost trfeai,ely.
Aynurrrl ,-pt rudnp ir brr g grusx
LONG HOSE LOT.: Quarity 'rfX01Itx"rlt.ISt is used u'rrn au
machine,, hcing a high per'formance how proved over ,.situ))
years of farm usc. Unlike cable -tow machine. the Agij ircel
ho,c k either lard out or pi::►:cd up, Thi-, climioatiOn of drag
ensunti long _ liom-, life a; -well as nlakinr the .Aquarcel C:lplhle
of operation its loro grao; wilhout stallhi, .
FOLDING ARl11S: The arnis on the Aquix"I an: ca,il,
adju.,table fof spray height, i-k%lucing Kind c]riit problems. The
terms earn :rls-n he fulled rner to muke tramlxln around tllt
farm an easy Operation.
lt?1r niNk-r nr„1es are used ]chicle will ikm mulid) top- W-
SPECIF'IC XHONS
MODETr C150 C17a
HOSE LENGTH
FLOW (gpni)
WETTFr) wlr)TH
APPLICATION
MINIMUM I'RI-SSURE
AB' Your local Ucaicr is
P(1 RUX 9119, RICA, GEORGIA 30180
Phone: [phone] Fax: [phone]
49,'
57.5'
35-75
35-75
78'
78,
I" 5,,
.'.' .7
.40 psi
:>.l) psi

ABI AQUAREEL - MODEL C176 PERFORMANCE & APPUcAvON RATES
FLOW
' NOZZLE ANCHOR
I SPACING
SPEED IN FT./
MIN.
GPM
SIZE PRESSURE
(FT)
' (PSI) '
6
5
3
2.5
l2_ L_ 1.5
APPLICATION IN
INCHES
35
36 65
r C.11
0.15_
�0.22
I
0.29
1 0.37
# 0.48
44
_8
10 45
70
0.14
0.19
0.28
0.37
a,48
_0.58
53
l0 50
75
0.16
0.22
0.34
0.45
0.55
'� 0.75
66
"12 60
80
0.21,
0.28
0.42
0.50
0.70
0.83
NO. HOURS FOR COMPLETE REWIND:
1.5
_�2
3
4
5
6
LENGTH OF HOSE: 574 FT.
PERFORMANCE WILL VARY ACCORDING TO: WIND
GROUND CONDITIONS
SLOPE OF GROUND

be fabricated in almost any configuration. Some epoxy coated fittings
include stacks and hydrants as an integral part of the fitting.
Occasionally it may be necessary to connect PVC plastic pipe to steel
or CA pipe. This connection can be made with a coupling called a
transition or repair coupling. In -line valves can be supplied with
connections to gasket pipe.
Thrust blocking is required for gasket pipe. Most thrust blocks
will be concrete.. Manufacturers recommended thrust blocks at any
change in direction greater than 100. Figure 1,gives an example of
different arrangements for thrust blocks.
1
Figure I
1
a
Example of different arrangements for thrust blocks.
-5-

9
Figure 2. Anchorage blocks for in -line valves.
Table 1 is the forces encountered at end plugs. to calculate
forces encountered at bends,. tees and wyes, multiply the figure in
Table 1 by the factors given in Table 2.
Table 1. Thrust W at End Plugs
Thrust in lbs_ fnr test orPssure in nsi
Pipe Diameter
(inches)
100 PSI
150 PSI
206"PSI
__... .
250 PSI
1k
295
440
590
740
2
455
680
910
1140
2-L,
660
990
132'0
1650
3
985
1480
1970
2460
4
1820
2720
3630
4540
6
3740
5600
7460
'9350
8
64-90" �
9740
13, 0C10
16,200
10
10,650
16,000
21,300
26,600
12
.15,150
22,700
30,200
37,800
14
20,600
30,800
41,100
51,400
16,
26,600
39,800
53,100
66,400
M

4
Im
Table 2. - Factors for Calculating Thrust lJ for
Elbows a n'd Tees.
Elbows: 900
= 1.41ik-- Tees = 0.70 L
45°
= 0.76
30°
_ 0.52
-22:5° _
'0.39
Table 3 gives the safe bearing load for different soil types.
Table 3. Safe Bearing Load
Soil lb/ft2
Mulch, peat and similar 0 a
Soft Clay 1000 0 Zv�1J
Sand 2000
Sand and gravel 3000
Sand and gravel cemented
with clay 4000
Hard shale 10,000
Thrust block area t ft2 } _ ld . Thrust (Table 1 & Table 2 )
T_ Soil bearing strength a e 3).
In placing concrete thrust blocks, check with the -'manufacturer -of the
pipe being used to ensure that the correct size thrust blocks are
being used.
There are a number of machines that can be used to prepare the
trench for PVC plastic pipe. Soil types, moisture content, depth of
trench required and type and diameter of pipe must be considered.
Generally chain trenches, wheel trenches,-backhoes-, or vibrating plows
will be used for trench preparation. The vibrating plow can only be
used for solvent weld PVC pipe and generally is limited to the smaller
diameter of pipe. Under most conditions the chain trencher or wheel
trencher will be faster than the backhoe. Where wide trenches for large
pipe are required, the backhoe will be most satisfactory. If soil
conditions permit, long stretches of open trench will expedite pipe
installation. However, if rain is forecast the pipe should be installed
and the trench backfilled_ To avoid sharp turns in the line at obstructions,
trenches should be curved within limits of curvature of the pipe.
-7--

State of North Carolina
Department of Environment, Health, and Natural Resources
Wilmington Regional Office
James B. Hunt, Jr., Governor Division of Environmental Management Bob Jamieson
Jonathan B. Howes, Secretary Water Quality Section Regional Manager
SEPTEMBER 20, 1994
Mr. Gary Scalf
Murphy Farms, Inc.
Post Office Box 759
Rose Hill, North Carolina 28458
Subject: Water Quality Complaint Investigation
Dark Branch Pond
Duplin County
Dear Mr. Scalf:
This letter is to inform Murphy Farms about a water quality
complaint investigation performed on September 13 & 16, 1994 by
Division staff. The writer responded to a water quality complaint
concerning a man-made pond located along NC Highway 11 a few miles
north of Kenansville, as shown on the enclosed visual aid. The pond
contained dense accumulations of a blue-green algae known as
Anacystis cyanea. This algae blooms in water temperatures of 15 to
30' C and in conditions of stagnant water receiving nutrients ( such
as nitrate, ammonia, and especially phosphorus).
The investigation was performed to determine the cause of the
algal bloom by performing a land survey in the area of the pond.
There were several observations made concerning nutrient discharges
to the pond. The pond receives drainage from farm fields presently
planted with coastal bermuda. A small, independent swine farming
operation is located immediately adjacent to the pond's west shore
(lagoons are approximately 100 feet from the pond). In addition,
the Murphy/BAT swine farming operation is located upstream of this
pond.
The exact cause of the pond upset is not presently known.
However, the writer did see the potential for stream degradation
upon inspection of the BAT operation. The spray irrigation gun was
noticed to spray into, and over, a swale that drains the farm yard
adjacent to the swine houses. A picture is enclosed. Calvin, the
facility contact, indicated that there was a pasture crop in the
early growth stage. We also witnessed run -of f due to the sparse
vegetation and long duration spray rotations of the spray gun
equipment. This run-off went into the drainage swale. We witnessed
ponding of irrigation wastewater adjacent to an earthen berm within
one area of the spray field closest to the entry road. We observed
a wet area in the road next to the ponded area of the field.
127 Cardinal Drive Extension, Wilmington, N.C. 28405-3845 0 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer

Mr. Gary Scalf
September 20, 1994
Page Two
The Dark Branch drains the ridge where the Murphy/BAT swine
farming operation is located, as can be observed from the visual
aid. The drainage ditch which was sprayed over, and into, is not a
perennial stream and water quality samples within the unnamed
headwaters of Dark Branch were not taken. This letter is not a
violation notice. However, in addition to informing the pond owners
of the possible nutrient pathways leading into the pond, I wanted
to alert Murphy Farms personnel of the poor water quality within
the downstream pond. Cooperation from the Murphy/BAT operation in
regard to runoff abatement will be greatly appreciated. For
example, not spraying into a drainage swale designed to remove
stormwater from the facility, reducing the instantaneous spray rate
over the early pasture crop, discontinuing spraying operations upon
observations of runoff or ponding, and keeping the spray irrigation
activities within the field.
The algae in Dark Branch Pond can be toxic if it contains
acute amounts of hepatotoxic cyanobacteria. Species including
horses, cattle, sheep, dogs, swine, and waterfowl are susceptible
to poisoning from the ingestion of the toxic bacteria. The pond
does not have good water exchange because it is close to the
headwaters of the drainage basin. Preliminary testing did indicate
that the pond water pH was 9.4 and the dissolved oxygen was zero in
the lower segments of the pond (pretty bad water quality) . The pond
owners have been advised of potential nutrient passageways into the
pond. The cooperation of the Murphy/BAT operations staff in regard
to potential runoff abatement procedures will be greatly
appreciated.
This letter was generated
have questions concerning the
contact me at [phone].
murphy.994
for informational purposes. If you
subject or wish to comment, you may
Sincerely,
7
Jim Bushardt, P.E.
Environmental Engineer
-cc-:--W'i=lm fgton-Office-WQ Complaint Files (Duplin Co.)

girl
n�_ ea /1 .�� { ,i it p ! i.:•.•:li i
n � _
n.
lZ
.�•.
' -420= l
rNJ 1 ha l T�\
Cem 32. ' �J
yernle
i•� _ tLu E Cfwpej
r4' Ct ��5! / IP} .ii • �5 t �---�/ 1_rl \ ,
\1 i
n / -C �—
s .\� , 31
Tim Iq ,y �, ,/� +' • .�- ,/
/.! - --x� / . � ' ��) ._-I J ! / _ N/ Ski � -� _ ���� ' 1• ' "��,
^:AfIV lv LfJ i z32 KENANSVILLE 66 XM ' cJCJ z3 {{
t531V NW 4 235 1 1M 1ENJ0rt_GECL0Gtr AL $WAVE,. RE
E 1:24 OW Z36
.a1r MRS 1 ROAD CL,ASSIEIC/
4 0 Primary highway, Z Phi
1000 70tl0 Y, fight-f
t hard suriace.___._� improl
yp� woo Secondary highway,
SET 7= mu 9= f00pp hard surface —.----- _-.� Unimf
_RVAL 2 METERS {� Interstate Route O U- S- Rol
UTICAL DATUM OF 1929
TO THE NEAREST 0.1 METER
TO THE NEAREST 0•5 METER SUMMERLINS CRO
DNAt. MAP ACCURACY STANDARDS QUADRANGLE tOCATION SW/4 SEVEN SppdrjaS t
SURVEY. RESTON, VIRGINIA 22092 CONTOURS AND ELEVATIONS N3500—w77t
> AND SYMBOLS iS AVAILABLE ON REQUEST IN METERS
1980
nmt --

A i"i �4 'tl,�Illl [r i t , 1. : � . lb,", .1 ��. , _; .: " "

it 4, Abd: 9
kmkm� ��lv - mail,
FARMSINC.
P. 0. BOX 759 ROSE HILL
PHONE : (91 D) 289 -- 2111 NORTH CAROLINA 28458
b - ' I_A r LIhFF'
INSIDE 0P )k l7iY.t; - — 12_h[e' _...,___._.—_�..._.
.,TAti,1N+'- Pglr, i
HORIZONTAL OFFSET FOR
CLAY LINER - 51.06'
TOP 00, DIKE
Illr�-'�r•.
5p115 RMUIRING
Cl AY 1.INFR—.
1)
1.LA LLNf.F'
LINER./DIKE CROSS SECTION.
2600 NURSERY
N.T.S.
DARK BRANCH WARM
r
a— STRIP TOP5)(111. BfFORF FILI.INfy NVE
FExisnNG xRADF
i
DUPLIN
COUNT'i
L.) AWN Br 11T?
JULY 9.
1997
CHECKED BY' JNT
SHEE i 4
I)F 4
SCALE: NONE

DISTURBED AREA
18" MIN
E-
OVERALL TRAP =
DEPTH (SEE RAN) \
5EpN+1FN7 STORAGE
/ DEPTH (SEE PLAN)
NCDOT 057
WASHED STOV& —
— 5' MIN
1 5'
I 1 { S' MAX
C'Ci1IAdCn T-\�-
���h. STORAGE rnl 1
DUPL1N COUNTY
ORA WN 6 Y.• JiD
ULY 9, 19917
CHECKED t3Y: JST
JULYHEET 3 0E- 4
SCALE: NONE
r

C
- aO.00' PAD WIDTH -�- --
55.00BLDG WIDTH -
4 4 4 4 CONCRETE PAD q
q - d 4. 4 Is
BUILDING PAD SECTION
_ - - OVERHANGING LIMBS. POWER LINES{ ETC.
20' Min OVERHEAD CLEARANCE
FROM HIGH POINT OF ROADBEFI
WOODS IT OVERHANGING IMBS --
TR WI,IED TO I V MIN WOODS
Fn!tll y C'. /wJ �f�C
I I
- 22' MIN ()ITCH FO DITC:H - -- -----�
i {
14' MIN
Au WFADAER TRAVEL WIDTH I
�..._ t/2`,IVT 1/2'/Fr I i
��Ill��illII�IIIII� �T
4
COMPACTED WELL -DRAINED ROAIJIBED
SUTABLE FOR All WEANER CONDT'ON5 TYPICAL D�TCH
SLOPES
�- -- SHOULDER OTC. ES ------
- PROVUE AL*<QJATE 011TLET
FOR SHOULDER FATCHES
3 MINIMUM REQUIRED FARM ROAD_
2,,,) N. T.
Y ,Y --Y - Y
5:- M}S LENGTH
15' MIN OIAMETE; vu' VEF
SILCUR:,
ENTRANCE WUS- BE PLACID
THAT 1/4 MILE VISIBILITY ,,
PROVIDED IN 8071• DIRECTIC
S'A'T MAINTA;vE'U ROAD - PAVED OR SOIL
AVERJEND
#'I MIN
OF TAPER/SFCuMTY
I.00A TI ON
q�'* OiN r s_ *EATtiiER TRAVEL **C'
cr
1 i — 22- Wh j -ITC . -0; C, DTI:
MINIMUM ENTRANCE REQUIREMENTS
N.T.S.
N.T.S.
MURPHY
FARMSINC.
P. 0. BOX 759 ROSE HILL,
DNE : (91 0) 289 - 2111 NORTH CAROLINA 28458 J
d
—'' —�s__
�T
I--�-_I 1►► _=1 I ICI 11-�1�
WIDTH
18 t FROM INWE TOP OF DIKE
---- I j--SET TOP OF PVC CAP AT
TOP OF DIKE TOP OF DIKE ElEVATICN
f 3/4" PVC PIPE DRILLED AND —�'-
' GLUM INTO 3' PIPE
FAINT RED -
I3' PVC PPL
- - I START PI MP
.
''I.�!fI-1!I�lil-llfl TYP}
-
-III=11I 1II_=1 I M
I I ;l I !____I I El I I -I ! l-
-1 I 1=1 l I=I I l�:=l ! Ed I i___ _ - - STOP PUMP
PACKF:LL AROUND STAFF GAUGE
I ---•-I ] I-----� I I ----I ! �—I .��' J NTH BENTONITE AND COMPACT
-------
I
I
la: BvRY D> PTFI MIS:
..-III II
5 STAFF GAUGE.
2 N.T.S.
2600 N'URSERY
CEMENT BLO' K PAD
I
ROAD ELEV. a EYIST1NC
�ARC4, PPE
PIPE SUPPORT SHALL BE
BACXF;U.LL' VATH CLAY
AND COMPACTED
r ''-L1,: ALE PLASTIC PIPE
DARK BRANCH FARM
0
LOW ENE} GRADE -
REFERENCE POINT
-- 180.00' PAD LENGTH
HIGH END GRADE
REFERENCE POINT
- -- -- 162,00' BUILDING LENGTH - -
3
- 111­11I.
l 7.71L11,,-,III---
z
i
I/4R SLOPE
4uvcatTE PAD
BUILDING PAD SECTION
IN U I
1. THE GROWER MAY USE EITHER
CONCRETE BLOCK SPLASH PAD OR
FLEXIBLE PIPE SCOUP. PROTECTION
DEVICE.
2. THE SPLASH PAD SHALL EXTEND
A MINIMUM OF 1.0` UPSLCPF ()F THE
PIPE END TO 4.0' BF -POND THE
OF THE SLOPE.
3. PLASMIC PIPE SHALL BE LONG-
ENOUGH TC FXTEND A MINIMUM"
4.0' FLAT ALONG THE LAGCO%
BOTTOM.
PIPE SUPPORT
I +- MIN OWRHANG OVER SMLASHPAO - '.0'
I
CONCRETE BLOCK SHALL BE LAIC
^ J TOGE TER TIGHTLY WITH NQ
GAPS BETWEEN
4.0 MINIMUM
FLEMLE PIPE SHALL SLIDE OVER
DISCHARGE PIPE A MINDML'M OF I'
AND SHALL BE SECURED WITH SCREWS
-PIPE SUPPORT
DISCHARGE PIPE -!
- I-G' mov
PIPE SUPPORT SHALL BE
BACKnLLED WITH CLAY �.
AND COMPACTED
4.0' MIN
SCOUR PROTECTION DEVICES
N. T.S.
PTI
N.T.S.
-III-� ► I --III- 3
LENGTH
COMPACTED GRANULAR SACKFILL
MATERIAL 1.0' MIN
111 I _� I I I==i III III I
77III,-_i Y111 Iil�l
v v v v v v v v v v V
��I vvvvvvvvvvv _IfI--I
Q v v v v v 6' DIAMETER SOCK COVERED,
EXISTING GROUND G. v v v PERFORATED PLASTIC PIPE
v
v vv
ail III C' v v I,DIIIIII,I
v 717 BACKFILL MATERIAL AROUND PIPE
`J v v SHALL BE A COARSE SAND WITH
I i I LESS THAN 5X PASSiNG #200
v ` I I I SIEVE AND SHALL. EIE COMPACTED
I III11 v v v ©v v _ TO 95X OF STANDARD PROCTOR
MAXIMUM DRY DENSITY
I� 2.0' MINIMUM
7 \ SUBSURFACE DRAIN PIPE
2.) N.T.S.
DOPLIN COUNTY
BRA WN B Y: JJD
JULY 9, 1997
CHECKED BY. • JST
SHEET 2 OF g
SCALE: NON4:E:l

IEMPORARY SEDIMENT TRAP
LENGTH - 34.00
WIDTH = 17.00
SEDIMENT STORAGE DEPTH = 4.67 -
MIN. WEIR LENGTH = 4.00
SEE DETAIL
2
3
OBSERVATION TRENCH
TILE INV. = 96.07 �y SEE GENERAL NOTE 11
(LOW PT) Ten ._7 U-
J
-------_� _ _ 2500' SETBACK f ROM BA� CHE ORS SOW FARM _�---- - -�~ �/ -
EARTHWORK CALCULATION DATA
METHOD USED: COMPOSITE
TOTAL EXCAVATION
5,154 CY •• EXCAVATED CLAY 0 CY
PAD AND DIKE FILL
4,454 CY • REO'D FOR UNER 2,157 CY
NET
700 CY CLAY BORROW 2,157 CY
SUITABLE FOR UNER
0 CY
WASTE
700 CY
•
FILL VOLUMES HAVE BEEN ADJUSTED BY 20% AND CLAY
VOLUMES BY 15% FOR SHRINKAGE DUE TO COMPACTION.
••
TOTAL EXCAVATION VOLUME INCLUDES UNDERCUT FOR
1.6' THICK CLAY UNER.
LEGEND
EXISTING WOODSLINE
5
EXISTING CONTOUR
-- - 50
FINISHED CONTOUR
8" PVC DISCHARGE PIPES
MINIMUM BUILDING / LAGOON
SETBACK LINE
sc------- s�
SUBSURFACE DRAIN PIPE
FENCE
------�---�
S WALE
-----� •--;- rD--------�-�-
TEMPORARY DIVERSION
} -
4' X 8' CONC. BLOCK
SPLASH PAD
'
STAFF GAUGE:
SOIL TEST PIT
P1, .. , t.~, .. , 0'1, ...
PAD, LAGOON, OFFSET
STAKEOUT POINTS
MURPHY�-
W_�1 R 11'l S INC.
P. 0. BOX 759 ROSE
PHONE : [phone] - 2111 NORTH CAROLI!`:A 28458
t--n Vw%jro LLL Yn l iVl\ iJ P'1 I n
TOP OF DIKE ELEV. = 104.10
BEGIN PUMPING ELEV. = 101.50
END PUMPING ELEV. = 99.20
CIAHCUC'r) DOTTOkA CA C1/ ..-01 It)
BENCHMARK (ASSUMED)
LAG BOLT IN 6" WILLOW TREE
ELEV. = 100.00
APPROX. 487 LF OF 6"
CORRUGATED PLASTIC
SUBSURFACE DRAIN TILE
WITH FILTER SOCK
SEE DETAIL
M
CONTROL POINT #43
REBAR
N = 5077.1694
E = 4737.6836
ELEV. = 101.36
I
100 CONTROL POINT #29
- - - - -
I I I REBAR
/f06
�
/ II: 4
OD
O
�o
r
O _
rT1 N
I I
TAIL DITCH TO
MEET EXISTING
�0 GRADE
-103 0-
P2
li-t j
+ /
�/ ' LOW END OF PAD -1
INV. = 97.21 ELEV. = 103.9
I
PRECAST CONCRETE PULL PLUG B
TOP ELEV = 105.82
BOTTOM ELEV = 103.15
INV OF DISCHARGE PIPE = 101-98
RECORDED SETBACK WAIVER OBTAINED FROM
NEIGHBOR TO WEST. DOCUMENT RECORDED IN -_ -
DEED BOOK 1214 PAGE 374, DUPLIN CO.
GRAPHIC SCALE
20 40 flo
( IN FEET )
1 inch = 40 tt
N = 5220.3434
E = 5073.5893
ELEV. = 97.64
1 1
TEMPORARY DIVERSION I
c7 SEE DETAIL
_ SCOUR PROTECTION 2 Q,
DEVICE, SEE DETAIL
INV. * LAGOON = 101-�O -
-- 12.00'
WIDTH_ yg
TYP) 4
to TAIL DITCH TO 0
101 MEET EXISTING '�
80 LF 8 DISCHARGE Oil /
PIPE O 0.60% SLOPE + � O GRADE
L.4 0101
TILE INV. = 98.50 ,
' _j
03,6 -'`" (HIGH PT)
1�
----�--, 517 SD
1__
80.00' PAD LENG P3 �C 01 �
g�
a 'r
� m�
0
SWALE HIGH
END INV = 103.75
Oil
CONTROL POINi #13
Rr-BAR
N = 4826 3791
E = 4881.4960
ELEV. - 1(,5.70
ELEV. = 104.35
1
TAIL DITCH TO
0.25l6-SLOPE
®
10-} r�-MEET EXISTING
o
00
l� GRADE
i
STAKEOUT
OFFSET
50' (TYP)
1
c,i
01 3
'
FEED PA(
CONTROL POINT #22
t LEV. = 10j�.00
REBAR
1 N - 4894.8449
L-24' L_CADOUT
CHUTE
E = 5149.6977
ELEV. = 103.63
+ �.
GENERAL NOTES:
1. ELEVATIONS SHOWN ON THIS PLAN ARE BASED ON AN ASSUMED BENCH-
MARK ELEVATION AND DO NOT REPRESENT MEAN SEA LEVEL DATUM.
2, ANY HEAVY VEGETATION AND/OR ROOT MAT SHALL BE STRIPPED FROM
PAD AND LAGOON AREAS PRIOR TO PLACING FILL. ACTUAL STRIPPING
REQUIREMENTS SHALL BE SITE SPECIFIC, AND SHALL BE DETERMINED IN
THE FIELD BY MURPHY FARMS PERSONNEL. THIS MATERIAL SHALL
BE STOCKPILED AND MAY LATER BE RESPREAD ON BACKSLOPES TO HELP
REESTABLISH VEGETATION, BUT SHALL NOT BE USED AS STRUCTURAL FILL.
INDIVIDUAL ROOTS OF 2 INCHES IN DIAMETER OR GREATER WILL NOT BE
ALLOWED IN FILL SECTIONS. ANY STUMPS ENCOUNTERED IN LAGOON SIDE
SLOPES OR BOTTOM MUST BE REMOVED.
3. THE SOILS INVESTIGATION DONE BY MURPHY FARMS INDICATES SOILS
WHICH WWLL REQUIRE CLAY LINING, THE BOTTOM AND SIDE SLOPES
OF THE LAGOON SHALT. BE UNDERCUT FOR A 1.6' THICK LINER. THE
LINER MATERIAL SHALL BE THOROUGHLY AND UNIFORMLY COMPACTED
SUCH THAT THE PERMEABILITY AFTER PLACEMENT SHALL NOT EXCEED
1.25 X 10--6 CM/SEC. UNDISTURBED CORE SAMPLES OF THE LINER
MATERIAL WILL BE TAKEN AFTER COMPLETION AND WILL BE LAB TESTED
TO CONFIRM THE PERMEABILITY. THE MURPHY FARMS ENGINEERING
DEPT. MUST APPROVE LINER MATERIAL PRIOR TO PLACEMENT. SEE
LINER / DIKE CROSS SECTION DETAIL ON SHEET 2.
4. THE LAGOON IS BEING PLACED IN A WET AREA NTH THE WATER TABLE
BEING WITHIN THE EXCAVATED DEPTH. IT IS IMPERATIVE THAT THE
CONTRACTOR INSTALL DRAINAGE MEASURES AT THE START OF THE
PROJECT AND MAINTAIN THEM UNTIL ALL LAGOON GRADING AND LINING
IS COMPLETED.
5. THE LAGOON SHALL BE PRECHARGED WITH WATER TO AT LEAST 1/2 THE
TREATMENT ZONE DEPTH AS SOON AS THE LINER IS COMPLETE AND HAS
BEEN TESTED. THIS IS IMPORTANT TO HELP REDUCE START-UP ODORS
AND TO GUARD AGAINST SLOUGHING OF THE LINER MATERIAL
6. ALL FILL MATERIAL PLACED ON THE BUILDING PAD AND LAGOON DIKES
SHALL BE COMPACTED TO 95% OF THE STANDARD PROCTOR MAXIMUM DRY
DENSITY. IT IS RECOMMENDED THAT COMPACTION BE DONE WITH A
SHEEPSFOOT ROLLER.
7. BUILDING PAD ELEVATIONS SHOWN ON THIS PLAN REPRESENT BLDG.
SLAB SUBGRADE. SEE PAD CROSS SECTIONS FOR GRADE REFERENCE
POINT,
8. BUILDING PAD AND LAGOON DIKE SIDE SLOPES ARE 3:1 UNLESS
OTHERWISE NOTED ON PLAN.
9. ANY WATER SUPPLY WELLS PLACED ON THE SITE MUST BE A MINIMUM OF
100' FROM THE CLOSEST POINT OF THE LAGOON.
10. THE FOLLOWING ITEMS SHALL BE DONE WITH REGARDS TO THE LAGOON
CONSTRUCTION BEFORE THE FACILITY IS CERTIFIED: LAGOON DIKES
FERTILIZED, SEEDED AND MULCHED INSIDE AND OUT; APPROVED SCOUR
PROTECTION DEVICES INSTALLED AT THE DISCHARGE PIPES, THE
STAFF GAUGE INSTALLED.
11. BEFORE BEGINNING EXCAVATION AN OBSERVATION TRENCH SHALL BE DUG
AROUND THE LAGOON AS SHOWN TO DETERMINE WHETHER DRAIN TILE IS
PRLSEN T IN THE LAGOON AREA. THE TRENCH SHALL BE A MINIMUM OF
5 FEET DEEP AND 4 FEET WIDE AND SHALL BE 25' OUTSIDE THE TOE
OF THE LAGOON. IF ANY DRAIN TILE IS FOUND IT SHALL BE REMOVED
COMPLETELY FROM THE LAGOON AREA. OUTSIDE THE TRENCH THE TILE
SHALL BE EITHER CAPPED OFF OR REROUTED AROUND THE LAGOON AS
DIRECTED BY THE ENGINEER.
12. THE, EROSION CONTROL MEASURES SHOWN ON THIS PLAN ARE INTENDED
AS A GUIDE. THE EROSION AND SEDIMENTATION CONTROL REGULATIONS
IN NORTH CAROLINA ARE PERFORMANCE BASED AND ADDITIONAL MEASURES
MAY BE REQUIRED TO PREVENT SEDIMENT FROM LEAVING THE SITE. IT IS THE
LAND OWNERS RESPONSIBILITY TO PROVIDE AND MAINTAIN ALL SUCH MEASURES
THROUGHOUT THE CONSTRUCTION PERIOD.
/--150' DIA. TURN AROUND .-/
5 QC)' PROPER UNr-� BACK
��
1
1
SITE EVALUATION COMPLETED JULY 8, 1997
ALL SURVEY LOCATION AND ELEVATION DATA COLLECTED
BY MURPHY FAMILY FARMS ENGINEERING DEPT.
DARK BRANCH FARM
-��nn EIZ Y
REVISIONS
VIAOF-
' � DESCRfr ,�N
WV I- �11`19 L6
la
SEEDING NOTES:
1. ALL DISTURBED AREAS SHALL BE SEEDED, FERTILIZED AND MULCHED AS
SOON AS POSSIBLE AFTER FINAL GRADING IS COMPLETED. THIS
INCLUDES INSIDE SLOPES OF THE LAGOON.
2. PREPARE DISTURBED AREAS FOR SEEDING BY GRADING IN ALL SURFACE
WATER DIVERSIONS AND SHAPING TO FINAL GRADES SHOWN ON PLAN.
3, APPLY LIME AND FERTILIZER THEN DISK TO PREPARE A 3 TO 4 INCH
SMOOTH SEEDBED. APPLY SEED AND FIRM SEEDBED WITH A
CULT1PACKER OR SIMILAR EQUIPMENT. APPLY MULCH AND SECURE WITH
A MULCH ANCHORING TOOL OR NETTING.
SOIL AMENDMENTS:
3000 LBS OF 10-10-10 FERTILIZER (1000 LBS/ACRE)
6 TONS OF DOLOMITIC LIME (2 TONS ACRE)
300 BALES OF SMALL GRAIN STRAW 100 BALES/ACRE)
SEEDING SCHEDULE:
winter
180
LBS
OF
FESCUE (60 LBSy'ACRE) -
SEPT 1 TO NOV 30
120
LBS
OF
RYE GRASS (40 LBS/ACRE)
- DEC I TO MAR 30
90
LIDS
OF
RYE GRAIN (30 LBS/ACRE)
- nurse crop for fescue
30
LBS
OF
UNHULLED COMMON BERMUDA GRASS (10 LBS/ACRE)
summer
- JAN 1 TO MAR 30
180
LBS
OF
'PENSACOLA BAHIA GRASS
(60 LBS/ACRE)--MAR 15 TO JUNE 15
24
LBS
OF
HULLED COMMON BERMUDA
GRASS (8 LBS/ACRE)-APR 1 - JULY 31
TOTAL AREA TO BE SEEDED AND MULCHED = 3 ACRES (APPROX)
"f)011 'l'.:
'1'0Q `; 7,
CiRAWN BY:
9,
1 �4 7
CHECKED &Y. JS;