310828_HISTORICAL_20171231

�,AM
NORTH CAROLINA
Department of Environmental Qual

.AN A- ; TA
NCDENR
North Carolina Department of Environment and Natural Resources
Beverly Eaves Perdue
Governor
Ronald Greg Brown
D and B Nursery, Site # 2 (5-8)
1042 Stockinghead Road
Rose Hill, NC 28458
Dear Ronald Greg Brown:
Division of Water Quality
Coleen H. Sullins
Director
May 28, 2010
Dee Freeman
Secretary
Subject: Certificate of Coverage No, AWS31(828
D and B Nursery, Site # 2 (5-8)
Swine Waste Collection, Treatment,
Storage and Application System
Duplin County
In accordance with your Notification of Change of Ownership. received May 26, 2010, we are hereby
forwarding to you this Certificate of Coverage (COC) issued to Ronald Greg Brown, authorizing the
operation of the subject animal waste management system in accordance with General Permit
AWG 100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for the P and B Nursery, Site # 1, located in Duplin County, with a swine animal
capacity of no greater than the following annual averages: 7JUN
Wean to Finish: Feeder to Finish: Boar/Stud:Wean to Feeder: 3552 Farrow to Wean: Gilts:����
Farrow to Finish: Farrow to Feeder: Other:
If this is a Farrow to Wean or Farrow to Feeder operation, there may be one boar for each 15 sows. Where
boars are unnecessary, they may be replaced by an equivalent number of sows. Any of the sows may be
replaced by gilts at a rate of 4 gilts for every 3 sows.
The COC shall be effective from the date of issuance until September 30, 2014, and shall hereby void
Certificate of Coverage Number AWS310828 dated October 1, 2009. Pursuant to this COC, you are
authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Please „pay careful_ attention to the
record keeping and monitoring conditions in this permit. Record keeping forms are unchanged with this
General Permit. Please continue to use the same record kee-oing forms.
1636 Mall Service Center, Raleigh, North Carolina 27699-1.636
Location: 2728 Capital Blvd., Raleigh, North Carolina 27604 One
Phone: [phone] FAX: [phone] Customer Service: 1-877�623-0748 NO Carolina
lntemet www.ncrraterquality,org �1�N� //�
An Equal Opportunity 1 Affirm11 Affirmative Action Erriplcyer L

If your Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
The issuance of this COC does not excuse the Permittce from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Per 15A NCAC 2T ,0105(h) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100-foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
sprat field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.5A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, then an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Unit for information on this
process. Unless such a request is made within 30 days, this COG shall be final and binding.
In accordance with Condition 11.22 of the General Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning; Tropical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You
may find detailed watch/warning information for your county by calling the Newport/Morehead City, NC
National Weather Service office at [phone], or by visiting their website at:
www.erh.noaa.gov/er/mhx/
This facility is located in a county covered by our Wilmington Regional Office, The Regional Office
Aquifer Protection Staff may be reached at [phone]. If you need additional information
concerning this COC or the General Permit, please contact the Animal Feeding Operations Unit staff at
[phone].
Sincerely,
for Coleen H. SulIins
Enclosure (General Permit AWG100000)
cc: (Certificate of Coverage only for all ccs)
Wilmington Regional Office, Aquifer Protection Section
Duplin County Health Department
Duplin County Soil and Water Conservation District
APS Central Files (Permit No. AWS310828)
AFO Notebooks
Murphy -Brown, LLC
-2-

W 1 ZO
ANIMAL WASTE UTILIZATION PLAN
Producer: MARTY BLIZZARD
Location: 141 N BLIZZARD TOWN RD
BEULAVILLE NC 28518
Telephone: [phone]
Type Operation: Existing Wean to Feeder Swine
Number of Animals: 3552.00 pigs
(Design Capacity)
STORAGE STRUCTURE: Anaerobic Waste Treatment Lagoon
APPLICATION METHOD: Irrigation
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of -commercial fertilizer required for the crops
in the fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of'the crop to be
grown and the nutrient content of the waste. Do not apply
more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall be applied to land eroding at less than
5 tons per acre per year. Waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on saturated soils, when it is raining,
or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed
under DWQ regulations.
RECEIVED I DENR / DWQ
AQUjFFR-PP0TFf:T1nN gFrTION
MAR 17_
Page: 1

ANIMAL WASTE UTILIZATION PLAN
5. Wind conditions should also be considered to avoid drift and
downwind odor problems.
6. To maximize the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more than 30
days prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. If
you choose to change methods in the future, you need to revise this
plan. Nutrient levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from your
waste management facility. In some cases you may want to have plant
analysis made, which could allow additional waste to be applied.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
This waste utilization plan, if carried out, meets the requirements
for compliance with 15A NCAC 2H .0217 adopted by the Environmental
Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
3552 pigs x .40 tons waste/pigs/year = 1420.8 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
3552 pigs x .96 lbs PAN/pigs/year = 3409.92 lbs. PAN/year
Applying the above amount of waste is a big job. You should plan
time and have appropriate equipment to apply the waste in a timely
manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
Page: 2

ANIMAL WASTE UTILIZATION PLAN
TABLE 1: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
------
APPLY
RESID.
APPLIC
METH
N
TIME
5186
lA
FOA
C
120
107
43
3.24
346.68
I
+MAR-
U Nil
5186
3.24
I�IA
�FOA
�
�S5
�110
10
+OCT4
MAR
5186
1A
DSB
28
112
0
�FOA
I
�3.24
�362.88
+JUN-
SEPT 15
5186
-1A
SG
1
0
I
�50
�3.24
�162
+SEP--
APR
5186
1B
FOA
C
I
�120
�107'
�43
�3,15
�337.05
+MAR-
JUN
5186
1B
w
�FOA
I
�55
�110
�.O
13.15
�346.5
+OCT-
MAR
5186
1B
DSB
0
�FOA
I
�28_
�112
13,15
�352.-S
+JUN-
SEPT 15
5186
SG
1
0
I
�50
13.15
1157.5
+SEP-
APR
5186
1C
FOA
C
I
1120
1107
�43
13.71
1396.97
+MAR-
JUN
5186
�IC
0
IFOA
JW
I
155
1110
13.71
1408.1
+OCT-
MAR
Page: 3

ANIMAL, WASTE UTILIZATION PLAN
5186 I�1C 1FOA DSB �28 112 0 �3.71 �415.52
I +JUN-
SEPT 15
5186 �TC SG 1 50 0 �3.71 �185_.5
I +SEP-
APft
END
I
TOTALI3827.9
- Indicates that this field is being overseeded (i.e.
interplanted) or winter annuals follow summer annuals.
+ - Dates shown reflect optimum uptake periods for nutrients. waste
appilcation may begin up to thirty(30) days prior to planting or
green -up of forages, and extend past.optimum dates shown if
plant growth, pumping conditions, and PAN loading rates permit.
NOTE: The applicator is cautioned that P and K may be over applied
while meeting the N requirements. In the future, regulations
may require farmers in some parts of North Carolina to have a
nutrient management plan that addresses all nutrients. This
plan only addresses nitrogen.
Page: 4

ANIMAL WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
See required specification 2.)
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
----
or
-------
APPLY
RESID.
APPLIC
METH
N
TIME
END
TOTAL10
- Indicates that this field is being overseeded (i.e. interplanted) or
winter annuals follow summer annuals.
+ - Dates shown reflect optimum uptake periods for nutrients. Waste
application may begin up to thirty(30) days prior to 'planting or
green -up of forages, and extend past optimum dates shown if
plant growth, pumping conditions, and PAN loading rates permit.
In interplanted fields (i.e. small grain, etc, interseeded
in bermudagrass), forage must be removed through grazing,
hay and/or silage. Where grazing, plants should be grazed
when they reach a height of six to nine inches. Cattle
should be removed when plants are grazed to a height of four
inches. In fields where small grain, etc, is to be removed
for hay or silage, care should be exercised not to let small
grain to reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too
high and this will definitely interfere with stand of
bermudagrass. This loss of stand will result in reduced
yields and less nitrogen being utilized. Rather than
cutting small grain for hay or silage just before heading as
is the normal situation, you are encouraged to cut the small
grain earlier. You may want to consider harvesting hay or
silage two to three times during the season, depending on
time small - grain is planted in the fall.
The ideal time to interplant small grain, etc, is late
September or early October. Drilling is recommended over
broadcasting. Bermudagrass should be grazed or mowed to a
height of about two inches before drilling for best results.
Page: 5

ANIMAL WASTE UTILIZATION PLAN
** Acreage figures may exceed total acreage in fields due to
overseeding.
* lbs AW N (animal waste nitrogen) equals total required nitrogen,
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and 2 above:
CROP CODE
CROP
UNITS
PER UNIT
C
CORN
BUSHELS
1.25
DSS
DOUBLE CROPPED SOYBEANS
BUSHELS
4
SG
SMALL GRAIN OVERSEEDED
AC
50
W
WHEAT
BUSHELS
2
TABLE 1
TABLE 2
TOTAL
TOTALS FROM TABLES 1 AND 2
WETTABLE
_ACRES
10.1
LBS AW N USED
^
3827.9
0
0
10.1
3827.9
* BALANCE
--417.98
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.
Page: 6

ANIMAL WASTE UTILIZATION PLAN
*** This number must be less than or equal to 0 in order to fully
utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffers, filter strips along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than
the acres shown in the tables.
See attached map showing the fields to be used for the utilization of
animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient
rich and will require precautionary measures to prevent over application
of nutrients or other'elements. Your production facility will produce
approximately 134.976 pounds of plant available nitrogen per year in the
sludge.
If you remove the sludge every 5 years, you will have approximately 674.88
pounds of PAN to utilize. Assuming you apply this PAN to hybrid
bermudagrass hayland at the rate of 300 pounds of nitrogen per acre, you
will need 2.2496 acres of land. If you apply the sludge to corn at
the rate of 125 pounds of nitrogen per acre, you will need 5.39904 acres
of land. Please be aware that these are only estimates of the PAN and
land needed. Actual requirements could vary by 25% depending on your
sludge waste analysis, soil types, realistic yields, and application
methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the
soil at the time of irrigation such that runoff or ponding occurs. This
rate is limited by initial soil moisture content, soil structure, soil
texture, water droplet size, and organic solids. The application amount
should not exceed the available water holding capacity of the soil at the
time of irrigation nor should the plant available nitrogen applied exceed
the nitrogen needs of the crop.
If surface irrigation is the method of land application 'for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables land 2. Failure to apply the recommended rates and
Page: 7

ANIMAL WASTE UTILIZATION PLAN
amounts of nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application
rates and amounts.
I
Tract i
1
Field l
Soil Type
5186
1
l lA l
FOA
5186
1 13 I
FOA
5186
1
l 1C l
FOA
5186
l -1A l
5186
1
l w-1A l
FOA
5186
--1A
FOA
5186 1 - 1B 1
5186
--1B FOA
5186
1
l -12 1 FOA
5186
-1C l
IAppli.cation
RatelApplic. Amount
l Crop
I
l (in/hr)
l (inches)
I *1.0
C
l .50
I
I
I
l *1.0
l C
I .50
I
I
l *1.0
1 C
l .50
1
I --
l *1
1 SG
l .5
l *1.0
l DSB
l .50
l *1.0
l W
l .56
I
l SG
I
1 *1
i .5
l *1.0
l DSB
.50
1 W
l *1.0
l .50
I
*1
_I
l SG
l .5
Page: 8

ANIMAL WASTE UTILIZATION PLAN
5186
5186
FOA
FOA
1 W
i
.50
50
*1.0
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations, the application amount shown cannot
be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180.00 days of temporary storage and
the temporary storage must be removed on the average of once every
6.00 months. In no instance should the volume of the waste be stored
in your structure be within the 25 year 24 hour storm storage or one
foot of freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply the
correct rates to the acres shown in Tables I and 2. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may
make this plan invalid.
Call your technical specialist after you receive the waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate prior to applying the waste.
NARRATIVE OF OPERATION
THIS PLAN IS WRITTEN ON AN TWO YEAR ROTATION WITH AN WETTABLE ACRE FOOTPRINT.
Page: 9

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity,.allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Alan when
there is a change in the operation, increase in the number of
animals, method of utilization; or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on'soil type,
available moisture, historical data, climatic conditions, and
level of management,.unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip) I .
5. Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
6. when animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be considered.
Page: 10

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component -of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
.(See Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to
wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways:
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist": Animal waste shall not be applied on
grassed waterways that discharges directly into water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
the site.
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc., -are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 11

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
18. If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22. Waste shall be tested within 60 days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when these
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
years. waste application records for all other waste shall be
maintained for five ( 5 ) years.
23. Dead animals will be disposed of in a manner that meets North
Carolina regulations.
Page: 12

ANIMAL WASTE - UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Naive of Farm:M&M FARMS
Owner/Manager Agreement
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. S
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
North Carolina Division of Water Quality (NCDWQ) before the new
animals are stocked. I (we) also understand that there must be no
discharge of animal waste from this system to surface waters of the
state from a storm event less severe than the 25-year, 24-hour
storm. The approved plan will be filed on -site at the farm office
and at the office of the local Soil and Water Conservation District
and will be available for review by NCDWQ upon request.
Name of Facility Owner: MARTY BLIZZARD
(Please print)
Signature: Date:
elf
Name of Manager(I different from owner):
Signature:
Date:
Name of Person Preparing Plan: (Please print) JOHNNY L . LANIER
Affiliation:DUPLIN SOIL AND WATER CONSERVATION DISTRICT
Phone No. 910-296-2120
Address (Agency): PO BOX 219
KENANSVILLE NC 28349
Signature: J Date: a D D
Page: 13

r
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per MRCS standards a 100 foot separation shall be maintained between water supply wells and any
lagoon or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Wilmington Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional_information_concerning
this COC or the General Permit, please contact Michelle Barnett at [phone] ext. 544.
Sincerely,
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
Wilmington Regional Office, Water Quality Section
Duplin County Health Department
Duplin County Soil and Water Conservation District
Permit File AWS310828
NDPU Files

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P. E., Director
Division of Water Quality
May 1, 2003
Marty Blizzard
Marty BIizzard #2
141 N. Blizzard Town Road
Beulaville NC 28518
Subject: Certificate of Coverage No. AWS310828
Marty Blizzard #2
Swine Waste Collection, Treatment,
Storage and Application System
Duplin County
Dear Marty Blizzard:
On April 28, 2003, the North Carolina General Assembly ratified Senate Bill 733 which directs the
Division of Water Quality (Division) to extend the expiration date of the.Swine Waste Operation General
Permit AWG100000. Therefore, the General Permit has been re -issued by the Division to extend the
expiration date to October 1, 2004. During the period of this extension the Division will be working with
all interested parties on the development of a new version of the Non -Discharge General Permit.
In accordance with your application received on February 20, 2003 and in accordance with the directive
of Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to Marty
Blizzard, authorizing the operation of the subject animal waste collection, treatment, storage and land
application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AWS310828 which expired on April 30, 2003.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Marty Blizzard #2, located in Duplin County, with an animal capacity of no
greater than an annual average of 3552 Wean to Feeder swine and the application to land as specified in
the facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or
Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary,
they may be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a
rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until October 1, 2004. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property. vow,
ENR
Non -Discharge Permitting Unit Internet httpJ/h2o.enr.state.nc.us/ndpu
1617 Mail Service Center, Raleigh, NC 27699-1617 Telephone [phone] Fax [phone]
Customer Service Center Telephone [phone]
An Equal Opportunity Action Employer 50% recycled/10% post -consumer paper

-ANIMAL WASTE.UTILIZATION PLAN
Producer: MARTY BLIZZARD
Location: 141 N BLIZZARD TOWN RD
BEULAVILLE NC 28518
Telephone: [phone]
Type Operation: Existing Wean to Feeder Swine
Number of Animals: 3552.00 pigs
(Design Capacity)
STORAGE STRUCTURE: Anaerobic Waste Treatment Lagoon
APPLICATION METHOD: Irrigation
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops
in the fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply
more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall be applied to land eroding at less than
5 tons per acre per year. Waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on saturated soils, when it is raining,
or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed
under DWQ regulations.
Page: 1

`ANIMAL WASTE UTILIZATION PLAN
5. Wind conditions should also be considered to avoid drift and
downwind odor problems.
6. To maximize the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more than 30
days prior,to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. if
you choose to change methods in the future, you need to revise this
plan. Nutrient levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from your
waste management facility. In some cases you may want to have plant
analysis made, which could allow additional waste to be applied.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
This waste utilization plan, if carried out, meets the requirements
for compliance with 15A NCAC 2H .0217 adopted by the Environmental
Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons; ft3, tons, etc.)
3552 pigs x .40 tons waste/pigs/year = 1420.8 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
3552 pigs x .96 lbs PAN/pigs/year = 3409.92 lbs. PAN/year
Applying the above ,amount of waste is a big job. You should plan
time and have appropriate equipment to apply the waste in a timely
manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.

ANIMAL WASTE UTILIZATION PLAN
TABLE 1: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
----
or
-------
APPLY
RESID.
APPLIC
METH
N
TIME
5186
120
1A
FDA _
C
107
43
3.24
346.68
I
+MAR-
1l6hl
5186
1A
0
3.24
�FOA
I
lW
�55
�110
�356.+OCT4
MAR
5186
1A
DSB
28
112
0
3.24
JFOA
I
�362.88
+JUN-
SEPT 15
5186
1A
SG
1
0
3.24
I
�50
1162
+SEP-
APR
5186
1B
FDA
C
;F107
43
337.05
I
1120
�3.15
�+MAR-
JUN
5186
12
W
55
IFOA
I
1
1110
1.0
13.15
1346.5
+OCT-
MAR
5186
113
DSB
0
352.•8
IFOA
I
�28
1112
13.15
+JUN-
SEPT 15
5186
SG
1
0
I
�50
13.15
�157.5
+SEP-
APR
5186
1C
FDA
C
396.97
I
1120
1107
143
�3.71
I+MAR-
JUN
5186
IC
0
IFOA
JW
I
�55
�110
13.71
�408.1
+OCT-
MAR
Page: 3

ANIMAL WASTE UTILIZATION PLAN,
5186 �-lC IFOA DSB 128 1112 10 13.71 1415.52
SEPT 15
5186 �1C SG 1 150 0 13.71-Ti 8 5-.5
T +SEP-
APR
END
T
TOTAL13827.9
- Indicates that this field is being overseeded (i.e.
interplanted) or winter annuals follow summer annuals.
+ - Dates shown reflect optimum uptake periods for nutrients. waste
appilcation may begin up to thirty(30) days prior to planting or
green -up of forages, and extend past optimum dates.shown if
plant growth, pumping conditions, and PAN loading rates permit.
NOTE: The applicator is cautioned that P and K may be -over applied
while meeting the N requirements. In the future, regulations
may require farmers in some parts of -North Carolina to have a
nutrient management plan that addresses all nutrients. This
plan only addresses nitrogen.
Page: 4

ANIMAL WASTE UTILIZATION PLAN\
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
See required specification 2.)
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LSS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
------
or
-------
APPLY
RESID.
APPLIC
METH
N
TIME
END
TOTAL I0
- Indicates that this field is being overseeded (i.e. interplanted) or
winter annuals follow summer annuals.
+ - Dates shown reflect optimum uptake periods for nutrients. Waste
application may begin up to thirty(30) days prior to planting or
green -up -of forages, and extend past optimum dates shown i•f
plant growth, pumping conditions, and PAN loading rates permit.
In interplanted fields (i.e. small grain, etc, interseeded
in bermudagrass), forage must be removed through grazing,
hay and/or silage. Where grazing, plants should be grazed
when they reach a height of six to nine inches. Cattle
should be removed when plants are grazed to a height of four
inches. In fields where small grain, etc, is to be removed
for hay or silage, care should be exercised not to let small
grain to reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too
high and this will definitely interfere with stand of
bermudagrass. This loss of stand will result in reduced
yields and less nitrogen being' utilized. Rather than
cutting small grain for hay or silage just before heading as
is the normal situation, you are encouraged to cut the small
grain earlier. You may want to consider harvesting hay or
silage two to three times during the season, depending on
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late
September or early October. Drilling is recommended over
broadcasting. Bermudagrass should be grazed or mowed to a
height of about two inches before drilling for best results.
Page: 5

C. m -
ANIMAL WASTE UTILIZATION PLAN
** Acreage figures may exceed total acreage in fields due to
overseeding.
* lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and 2 above:
CROP CODE
CROP
UNITS
PER UNIT
C
CORN
BUSHELS
1.25
DSB
DOUBLE CROPPED SOYBEANS
BUSHELS
4
SG
SMALL GRAIN OVERSEEDED
AC
50
W
WHEAT
BUSHELS
2
TABLE 1
TABLE 2
TOTAL
TOTALS FROM TABLES 1 AND 2
WETTABLE
LBS AW N USED
_ACRES
10.1
3827.9 a
0
0
10.1
3827.9
* BALANCE
- 417 . 9 8
*** This number must be less than or equal to 0 in order to
fully utilize the animal. waste N produced.
Page: 6

ANIMAL WASTE UTILIZATION PLAN
*** This number must be less than or equal to 0 in order to fully
utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffers, filter strips along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than
the acres shown in the tables.
See attached map showing the fields to be used for the utilization of
animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient
rich and will require precautionary measures to prevent over application
of nutrients or other elements. Your production facility will produce
approximately 134.976 pounds of plant available nitrogen per year in the
sludge.
If you remove the sludge every 5 years, you will have approximately 674.88
pounds of PAN to utilize. Assuming you apply this PAN to hybrid
bermUdagrass hayland at the rate of 300 pounds of nitrogen per acre, you
will need 2.2496 acres of land. If you apply t-he sludge to corn at
the rate of 125 pounds of nitrogen per acre, you will need 5.39904 acres
of land. Please be aware that these are only estimates of the PAN and
land needed. Actual requirements could vary by 25o depending on your
sludge waste analysis, soil types, realistic yields, and application
methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the
soil at the time of irrigation such that runoff or ponding occurs. This
rate is limited by initial soil moisture content, soil structure, soil
texture, water droplet size, and organic Solids. The application amount
should not exceed the available water holding capacity of the soil at the
time of irrigation nor should the plant available nitrogen applied exceed
the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables I and 2. Failure to apply the recommended rates and
Page: 7

ANIMAL WASTE UTILIZATION PLAN
amounts of nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application
rates and amounts.
(Application
RatelApplic. Amount
Tract l
Field
Soil Type
I Crop
l (in/hr)
1 (inches)
5186 1
lA 1
FOA
1 C
1 .50
I *1.0
5186
I I
l 1B
I
l *1.0
FOA
$ C
.50
5186
11C I
FOA
1 C
i .50
*1.0
5186
--1A
5186
I �I
l -- lA I FOA
5186
I
1 -lA 1 FOA
I
5186
I --1B
5186
1 --1B l FOA
5186
I
-12 1 FOA
.5186
1-1-
l -1C
I I I
l SG 1 ..5 l *1
DSB l .50 *1.0
I W 1 .50 1 *1.0
I .5
SG
l DSB
I w
I SG
50
1 .50
i .5
*1.0
Page: 8

ANIMAL WASTE UTILTZATION:PLAN
1 1
5186 I -1C
i
5186 I -1C I
FOA
FOA
I I
DSB I .50
I W I .50
i
*1.0
*1.0
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations, the application amount shown cannot
be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180.00 days of temporary storage and
the temporary storage must be removed on the average of once every
6.00 months. In no instance should the volume of the waste be stored
in your structure be within the 25 year 24 hour storm storage or one
foot of freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply the
correct rates to the acres shown in Tables 1 and 2. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may
make this plan invalid.
Call your technical specialist after you receive the waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate prior to applying the waste.
NARRATIVE OF OPERATION
THIS PLAN IS WRITTEN ON AN TWO YEAR ROTATION WITH AN WETTABLE ACRE FOOTPRINT.
Page: 9

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management,unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
5. Odors can be reduced by injecting the waste or disking after
waste application. waste should not be applied when there is
danger of drift from the irrigation field.
5. when animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be considered.
Page: 10

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component -of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 10C feet to
wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
15. Waste shall be applied in a manner -not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged inter surface waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly into water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
the site.
15. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 11

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
18. If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22. Waste shall be tested within 50 days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shA31 be used when these
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis -records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
years. waste application records for all other waste shall be
maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North
Carolina regulations.
Page: 12

ANIMALSWASTg UTILIZATION PLAN 3''-''
WASTE UTILIZATION PLAN AGREEMENT
Name of Fa=:M&M FARMS
Owner/Manager Agreement
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
North Carolina Division of Water Quality (NCDWQ) before the new
animals are stocked. I (we) also understand that there must be no
discharge of animal waste from this system to surface waters of the
state from a storm event less severe than the 25-year, 24-hour
storm. The approved plan will be filed on --site at the farm office
and at the office of the local Soil and Water Conservation District
and will be available for review by NCDWQ upon request.
Name of Facility Owner: MARTY BLIZZARD .
(Please print)
r Signature: i Date;
Name of Manager(I different from owner):
Signature:
Date:
Name of Person Preparing Plan: (Please print)JOHNNY L. LANIER
Affiliation:DUPLIN SOIL AND WATER CONSERVATION DISTRICT
Phone No. 910-296-2120
Address (Agency): PO BOX 219
KENANSVILLE NC 28349
Signature: Date: p0 V
Page: 13

Farm Number (Id
irrigation System
Number of Travel Lanes . # Interior Dries _ i A # Exterior Laries
1 [�. # Interior Laiies # Exterior Lanes
*Interior Lanes c # Exterior Lanes
Llb feet] Length of 0a
t, 5 [feet] Length of pull(L3)
4. Wetted Diameter 'O (feet] From field data sheet
5. Spacing 2 D D Hydrant Spacing [feet] -7/_ [as percent of wetted diameter]
6. Hydrant Layout Multiple Hydrants Single Hydrant Excessively spaced Hydrants
7. Read the irrigated area per travel pull for the given wetted diameter from the appropriate table and column
based on pattern, spacing, and travel lane location.
Travel Lane Leno h (Ll) Interior or / /9 Exterior (Lane/Hydrant)
U ?- (a) Acres start end of pull from Table FE Ss' Column_
8 z (b) Acres middle portion of pull (LI)
{Pull Length[,D {feet] X Wetted Width (feet])! 43,560
0 (c) Acres stop end of pull from Table i: r 2LL Column C.
-3 )-4_ Total acres for Travel Lane Length (U) (Sum: a + b + c)
Travel Lane Length (L2) Interior or Exterior (Lane/Hydrant)
3 5' (a) Acres start end of pull from Table ET 7 a Column
�0 (b) Acres noddle portion of pull (LI)
(Pull Length Glp [feet] X Wetted Width 4 OD [feet]} 143,560
p _ (c) P_;res =top end of pull from 7 able . C r' 7o Coll...= _ . C
3 1 s T otal acres for Travel Lane Length (U) (Sum: a + b + c)
Travel Lane Length (L3) Interior or I C- Extenor (Lane,Hydrm .t)
(a) Acr;.s start end of pull from Table Ec 93 Colurr�Ul g
(b) Acres r:uddi: oor tion of pull (LI)
(Pull Len h �5►_ [feet] X �G'e:'Led `Vid:h aaD {feet]) / 43,560
4 (c) Acres stop end n.` pull from Table EE t- Column L
?,� 1 Total acres for Travel Lane Length (L3) (Sum: a + b + c)
S. Niultip.� the tabulated irrigated acreage value per travel pull b,: the number of pull of each category in t«e
field. S=gym all of these and tits is the total irrigated acreage for the field.
3, 1-1 (a) Acres per Travel Lane Length (L1) X Lanes — 3, � y Acres
3, ! (b) Acres per Travel Lan Length (L2) X �� � Lanes = _ 3, 1S Acres
3, 71 1 (c) Acres per Travel Lane Length (L3) X R Lanes — 3. Acres
Total CANVMP NVettable Acres for field (Sum: 8a + 8b + 80
Wettable Acre Computational Work -sheet Completed by: l ��-~ Date:9%�

3
4
5
Gun make and model number it .04� /-1 .
Gun nozzle size , g� _ ['inch], ring orifice, taper bore orifice.
Gun arc angle 3 3 0 [degrees]
6. Travel lane spacing 'Z0 (7 [feet]. Indicate whether uniforms random.
Number of exterior hydrants - 2:,. Number of interior hydrants I
7. Gun wetted diameter [feet]
8. Gun pressure ` -r [psi].
measured, based on gun chart.
I observed at working gauge,
determined from gun charts, ' calculated (show calculations)
Operating pressure at hose reel ,5+ [psi], observed at working gauge,
< provided by owner.
Supply line size [inch] (Rom pump to last hydrant).
Supply line length 101D feet (maximum pumping distance).
Supply line type PVC, -- iC _aluminum.
Pump make and model number
* 14. Pump capacity, [pm].
* * 15. Engine make and model number
or
* * 16. Electric motor horsepower and rpn: [hp] (rc m]
Note: It is strongly recomment,-d that operating pressure at the reel and gun wetted
diameter be field determined.
* Locate each hydrant on a cope of the map. Indicate the start and stop of the sprinkler ca:
for ea:h travel lane and show dist2a:.e traveled. Show the location of the supply line.
Irritated acres will be detenrined by travel lane
`= Optional data, Lrnish where possiu =.
**` Info=ation furnished by
c r�
and./or
Sipature f Qzner acUity Rspresentative Si tyre of Te_hnical Specialist
Matti � %2zardf
Printed Name of Owner or Facility RepresentaU-
Date o c1 l
Printed Urine of Technical Specialist
Dated 2b ad
* * * Only the person 'or, persons collecting the data should sign the data sheet.

WETTABLE ACRES
IRRIGATION SYSTEM DESIGN PARMATERS
and
COMPUTATIONAL WORKSHEET SUMMARY
Landowner / Operator Name Marty Blizzard
Adress 141 N Blizzard Town Rd
Beulaville NC 28518
Telephone 91 Q-298-4251
TABLE 1 - Field Specifications
COUNTY Du tin
DATE 9/27/i)0
Tract
Number
Hydrant
or
field (1)
Number
acres
start end
wetted
area
acres
middle
wetted
area
acres
stop end
wetted
area
Approximate
Ma)dmun
Useable Size
of field (2)
(acres)
Table
column
Length
of
pulls
in feet
Width
of
pulls
in feet
Soil Type,(9b)
Slope
Crop(s)
Meftun
Applics w
Rate (3)
(Irdhr)
Mwdurnn
Application
per Irrigation
cycle (3)
fthes
5186
1A
0.42
2.82
0
3.24
EE85
B-C
560
220
FOA
0-5
CORN / WHEAT / SOYBEAN
0.5
1
5186
1 B
0.35
2.8
0
3.15
E170
B-C
610
200
FOA
0-5
CORN / WHEAT !SOYBEAN
0.5
1
5186
1C
0.42
3.29
0
3.71
EE85
B-C
651
220
FOA
0-5
CORN I WHEAT l SOYBEAN
0.5
t—
t:
i see attached map.
2 Total field acreage minus required buffer areas.
3 Refer to N.C. Irrigation guide, Field Office Technical Guide, Section 11 G. Annual application must nol exceed the agronomic rates for the sal and crop used.
Wettable Acre Computational Worksheet Completed by: Date

State of North Carolina `CEIVE
Department of Environment
and Natural Resources FEB 0 7 2001
Division of Water Quality
Michael F. Easley, Governor
William G. Ross, Jr., Secretary
January 31, 2001
MARTY BLIZZARD
MARY BLIZZARD #2
141 N. BLIZZARD TOWN ROAD
BEULAVILLE NC 28518
Y if
?WA
VC ED E N R
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Certificate of Coverage No. AWS310828
Mary Blizzard #2
Swine Waste Collection, Treatment,
Storage and Application System
Duplin County
Dear Mr. Blizzard:
In accordance with your application received on December 7, 2000, we are forwarding this
Certificate of Coverage (COC) issued to Marty Blizzard, authorizing the operation of the subject animal
waste collection, treatment, storage and land application system in accordance with General Permit
AWG I00000. This approval shall consist of the operation of this system including, but not limited to,
the management of animal waste from the Mary Blizzard #2, located in Duplin County, with an animal
capacity of no greater than 3552 Wean to Feeder swine and the application to land as specified in the
Certified Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations
as specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General
Permit or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS
143-215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This
request shall be made within 30 days of notification by the Division.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Certificate of Coverage AWS310828 _ •
Mary Blizzard #2
Page 2
This COC is not automatically transferable. A name/ownership change application must be
submitted to the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the
right to apply for an individual non -discharge permit by contacting the engineer listed below for
information on this process. Unless such a request is made within 30 days, this COC shall be final and
binding.
The subject farm is located in the Wilmington Regional Office. The Regional Office Water
Quality Staff may be reached at [phone]. If you need additional information concerning this
COC or the General Permit, please contact Theresa Nartea at [phone] ext. 375.
Z-err
ely,
A. Stevens
cc: (Certificate of Coverage only for all cc's)
Duplin County Health Department
W,,ilmington-RegionalsOFf ce;�Wfater�Quality; Sg i nQ
Duplin County Soil and Water Conservation District
Permit File
NDPU Files
0

8
State of North Carolina
Department of Environment and Natural Resources
Division of Water Quality
RECEIVED Non -Discharge Permit Application Form
(THIS FORM MAYBE PHOTOCOPIED FOR USE AS AN ORIGINAL)
IGEC 7 20ogGeneral Permit - Existing Animal Waste Operations
WATER 09'eiefffieestions have been completed utilizing information on file with the Division. Please
Nor1-Disc for completeness and make any corrections that are appropriate. If a
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
1. GENERAL INFORMATION:
1.1 Facility Name: Mary Blizzard #2
1.2 Print Land Owner's name: Marty Blizzard
1.3 Mailing address: 141 N. Blizzard Town Road
City, State: Beulaville NC Zip: 28518
Telephone Number (include area code): 910-298-4251
1.4 County where facility is located:
1.5 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a copy
of a county road map with the location of the farm identified): West of Beulaville. On West side of SR 1702 approx. 1.4
miles North of Hwy 24. T
1.6 Print Farm Manager's name (if different from Land Owner):
1.7 Lessee's / Integrator's name (if applicable; please circle which type is listed): Carroll's Foods Inc
1.8 Date Facility Originally Began Operation:
1.9 Date(s) of Facility Expansion(s) (if applicable):
2. OPERATION INFORMATION:
2.1 Facility No.: 31 (county number); 828 (facility number).
2.2 Operation Description: Swine operation
Wean to Feeder
3552- Certified Design Capacity
Is the ahove information correct? Xyes; = no. If no, correct below using the design capacity of the facility
The "No. of Animals" should be the maximum number for which the waste management structures were designed.
Tyne of Swine No. of Animals Type of Poultry No. of Animals Type of Cattle No. of Animals
0 Wean to Feeder 0 Layer 0 Dairy
0 Feeder to Finish 0 Non -Layer 0 Beef
0 Farrow to Wean (# sow) 0 Turkey
0 Farrow to Feeder (# sow)
0 Farrow to Finish (# sow)
Other Type of Livestock on the farm: No. of Animals:
FORM: AWO-G-E 7/7/99 Page 1 of 4 31- 828

Eft, CnVPj P,
lot, C.
E C,'E I A E D

.1
1 - ,
2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): 10+ ; Required Acreage (as listed in the AWMP): 10
2.4 Number of lagoons/ storage ponds (circle which is applicable):
2.5 Are subsurface drains present within 100' of any of the application fields? YES oq O (please circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES or NO (please circle one)
2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, N andards, etc.) (Swine Only)
YES or NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited?
What was the date that this facility's land application areas were sited? _ _t-LJ3 f 9[v
3. REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit application
for animal waste operations.
The CAWMP must include the following components. Some of these components may not
have been required at the time the facility was certified but should be added to the
CAWMP for permitting purposes:
✓r3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
`3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application.
"f. 3.4 The soil series present on every land application field.
—3.3.5 The crops grown on every land application field.
'-3-3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
!r-3.7 The PAN applied to every land application field.
�3.8 The waste application windows for every crop utilized in the WUP.
33.9 The required NRCS Standard specifications.
3.3:"10 A site schematic.
,-'3.3.11 Emergency Action Plan,
T3.12 Insect Control Checklist with chosen best management practices noted.
` SA 13 Odor Control Checklist with chosen best management practices noted.
---3.3.14 Mortality 'Control Checklist with the selected method noted.
►-3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility.
--'3.3.16 Operation and Maintenance Plan.
If your CAWMP includes any components not shown on this list, please include the
additional components with your submittal.
Applicants Initials
WA
FORM: AWO-G-E 7/7/99 Page 2 of 4 31 - 828

Facility Number: 31 - 828
Facility Name: Mary Blizzard #2
4. APPLICANT'S CERTIFICATION:
I, l" IR R r I B11Z Z AR D (Land Owner's name listed in question 1.2), attest that
this application for MhRrr 8j-1ZZd9k(Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be returned to me as incomplete. ��
Signature ,O Date Z .�Q D _
5. MANAGER'S CERTIFICATION: (complete only if different from the Land Owner)
(Manager's name listed in question 1.6), attest that this
application for (Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be returned as incomplete.
Signature
Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
1617 MAIL SERVICE CENTER
RALEIGH, NORTH CAROLINA 27699-1617
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
RECEIVED
DEC 7 20M
WATER CJ\J - Y SEGT 9N
�yo�-Disrhat8� perm
FORM: AWO-G-E 7/7/99 Page 3.of 4 31 - 828

L;'i',
- � s sr# r � .+y� 4 k 3 j - �-�r r -s K 1 .,ti• � � � d ••L.
-� 14 uN4'w� `',ri,�; iv' "+fit-T x t •S� �. ..V .,:7.�`!Si •ss x, ( ikd'hs r h r i''`,' ; 1- 4 _�' . z i 1 f iW !i d a f "fi�
�, e ti�.3,,�'{.. r'�• 1dr�'si'
Ego 4•. .�irr a.. ;w,.A. �i_ i Y ,,.}a;�n .. `.,�r� •�+°f P',�i'' eh,:r''SPyp'.ol
:. Wetfable tAcres Deternuriaton Certicati�on �l
- _. � � �.. y. - r+. is •:c: �S. ( `"`! �I,j•'���st P-'�?>.: .:r,., .. } +:� �+'7 .fir k� «. -1 M R; P s ,. r.;.Y,l�,,
Name of Facility: ri�i J. ri,% 90- -r m s Facility Number: - g2 $
Owner(s) Name: lm exr fin, �� �., 7 a � _ Phone NO
i.
Mailing Address: 141 gS/
By signing this form, the facility owner and Technical Specialist acknowledge the completion of the
Wettable Acres Determination. All necessary Wettable Acre Determination Field Data Sheets and
calculations were completed to conduct a Wettable Acre Determination. The facility's Waste
Utilization Plan has been amended as necessary to reflect actual wetted acreage. A copy of all
worksheets, calculations, and other Wettable Acres Determination documents, along with the
applicable Waste Utilization Plan and Wettable Acre Determination Certification will be filed with
the local Soil and Water Conservation District. A copy will also be kept on site with the Certified
Animal Waste Management Plan. Any future modifications must be approved by a technical
specialist and filed with the Soil and Water Conservation District prior to implementation. If any
modifications to the existing irrigation system or any new irrigation equipment was required to
adequately address the waste management needs of this facility, an Irrigation Specialist or
Professional Engineer has certified the design and installation below.' .
Owner Name: ,rgA
Owner Signature: Date: 9 /a I o 0
Technical Specialist Name: �e�,,.�,v. f Ln r,: e +^
Technical Specialist Signature- Date: 9L-laZo v
If assisted by an Irrigation Specialist or Professional Engineer please read and sign below:
Animal waste application equipment has been designed or modified to apply waste as necessary to
accommodate the waste management plan and according to MRCS Standards. Animal waste
application equipment has been installed according to NRCS Standards and is ready for use.
Irrigation Specialist/PE Name:
Irrigation Specialist/PE Signature -
Submit this form to:
Attn: Sonya Avant
Non -Discharge Compliance Unit
Division of Water Quality
1617 Mail Service Center
Raleigh, NC 27699-1617,
Date:
RECEIVED
1 DEC .7 2000
WATER QUALITY SECTION
Non -Discharge Permitting
WADC - 7/99

' ANIMAL WASTE UTILIZATION PLAN
_ t r
Producer: MARTY BLIZZARD
Location: 141 N BLIZZARD TOWN RD
BEULAVILLE NC 28518
Telephone: [phone]
Type Operation: Existing Wean to Feeder Swine
Number of Animals: 3552.00 pigs
(Design Capacity)
STORAGE STRUCTURE: Anaerobic Waste Treatment Lagoon
APPLICATION METHOD: Irrigation
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops
in the fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply
more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall be applied to land eroding at less than
5 tons per acre per year. Waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on saturated soils, when it is raining,
or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not -allowed
under DWQ regulations.
Page: 1

ANIMAL WASTE UTILIZATION PLAN
5. Wind conditions should also be considered to avoid drift and
downwind odor problems.
6. To maximize the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more than 30
days prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. If
you choose to change methods in the future, you need to revise this
plan. Nutrient levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste.analysis report from your
waste management facility. In some cases you may want to have plant
analysis made, which could allow additional waste to be applied.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
This waste utilization plan, if carried out, meets the requirements
for compliance with 15A NCAC 2H .0217 adopted by the Environmental
Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
3552 pigs x .40 tons waste/pigs/year = 1420.8 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
3552 pigs x .96 lbs PAN/pigs/year = 3409.92 lbs. PAN/year
Applying the above amount of waste is a big job. You should plan
time and have appropriate equipment to apply the waste in a timely,
manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
Page: 2

ANIMAL WASTE UTILIZATION PLAN
TABLE 1: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
or
-------
APPLY
RESID.
APPLIC
METH
120
N
TIME
51.86
lA
FOA
C
107
43
3.24
346.68
I
+MAR-
Nie]Q,
5186
FOA
0
I�1A
I �55
�110
�3.24
1356.4
+OCT
MAR
5186
1A
FOA
DSB
0
�28
T
1112
13.24
�362,88
+JUN-
SEPT 15
5186
lA
SG
1
0
T
�50
�3.24
�162
+SEP-
APR
5186
IB
FOA
C
�120
I
�107
�43
�3.15
�337.05
+MAR-
JUN
5186
--1B
FOA
W
0
�55
I
�110
�3.15
�346.5
+OCT-
MAR
5186
1B
FOA
DSB
0
�28
I
�112
13.15
�352.8
+JUN-
SEPT 15
5186
SG
1
0
T
150
13.15
�157.5
+SEP-
APR
5186
1C
FOA
C
I
1120
1107
143
13.71
�396.97
+MAR-
JUN
5186
�1C
FOA
JW
155
�110
b
�3.71
�408.1
I
+OCT-
9VA,ra
Page: 3

ANIMAL WASTE UTILIZATION PLAN
5186 I�IC �FOA �DSS 128 1112 0 �3.71 �415.52
SEPT 15
5186 SG 1 150 0 �3.71 1185.5
I +SEP-
APR
END
T
TOTAL13827.9
- Indicates that this field is being overseeded (i.e.
interplanted) or winter annuals follow summer annuals.
+ - Dates shown reflect optimum uptake periods for nutrients. Waste
appilcation may begin up to thirty(30) days prior to planting or
green -up of forages, and extend past optimum dates shown if
plant growth, pumping conditions, and PAN loading rates permit.
NOTE: The applicator is cautioned that P and K may be over applied
while meeting the N requirements. In the future, regulations
may require farmers in some parts of North Carolina to have a
nutrient management plan that addresses all nutrients. This
plan only addresses nitrogen.
Page: 4

' ANIMAL WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
See required specification 2.)
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
--------
APPLY
RESID.
APPLIC
METH
N
TIME
END
TOTAL10
-- - Indicates that this field is being overseeded (i.e. interplanted) or
winter annuals follow summer annuals.
+ Dates shown reflect optimum uptake periods for nutrients. Waste
application may begin up to thirty(30) days prior to planting or
green -up of forages, and extend past optimum dates shown if
plant growth, pumping conditions, and PAN loading rates permit.
In interplanted fields (i.e. small grain, etc, interseeded
in bermudagrass), forage must be removed through grazing,
hay and/or silage. Where grazing, plants should be grazed
when they reach a height of six to nine inches. Cattle
should be removed when plants are grazed to a height of four
inches. In fields where small grain, etc, is to be removed
for hay or silage, care should be exercised not to let small
grain to reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too
high and this will definitely interfere with stand of
bermudagrass. This loss of stand will result in reduced
yields and less nitrogen being utilized. Rather than
cutting small grain for hay or silage just before heading as
is the normal situation, you are encouraged to cut the small
grain earlier. You may want to consider harvesting hay or
silage two to three times during the season, depending on
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late
September or early October. Drilling is recommended over
broadcasting. Bermudagrass should be grazed or mowed to a
height of about two inches before drilling for best results.
Page: 5

` ANIMAL WASTE UTILIZATION PLAN
** Acreage figures may exceed total acreage in fields due to
overseeding.
* lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and 2 above:
CROP CODE
CROP
UNITS
PER UNIT
1.25
C
CORN
BUSHELS
DSB
DOUBLE CROPPED SOYBEANS
BUSHELS
4
SG
SMALL GRAIN OVERSEEDED
AC
50
W
WHEAT
BUSHELS
2
TABLE 1
TABLE 2
TOTAL
TOTALS FROM TABLES 1 AND 2
WETTABLE
_ACRES
10.1
LBS AW N USED
3827.9
0
0
10.1
3827.9
* BALANCE
-417.98
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.
Page: 6

' ANIMAL WASTE UTILIZATION PLAN
*** This number must be less than or equal to 0 in order to fully
utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffers, filter strips along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than
the acres shown in the tables.
See attached map showing the fields to be used for the utilization of
animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient
rich and will require precautionary measures to prevent over application
of nutrients or other elements. Your production facility will produce
approximately 134.976 pounds of plant available nitrogen per year in the
sludge.
If you remove the sludge every 5 years, you will have approximately 674.88
pounds of PAN to utilize. Assuming you apply this PAN to hybrid
bermudagrass hayland at the rate of 300 pounds of nitrogen per acre, you
will need 2.2496 acres of land. If you apply the sludge to corn at
the rate of 125 pounds of nitrogen per acre, you will need 5.39904 acres
of land. Please be aware that these are only estimates of the PAN and
land needed. Actual requirements could vary by 25% depending on your
sludge waste analysis, soil types, realistic yields, and application
methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the
soil at the time of irrigation such that runoff or ponding occurs. This
rate is limited by initial soil moisture content, soil structure, soil
texture, water droplet size, and organic solids. The application amount
should not exceed the available water holding capacity of the soil at the
time of irrigation nor should the plant available nitrogen applied exceed
the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables 1 and 2. Failure to apply the recommended rates and
Page: 7

ANIMAL WASTE UTILIZATION PLAN
amounts of nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application
rates and amounts.
(Application
RatelApplic. Amount
Tract
I Field I
Soil Type
I Crop
I (in/hr)
I (inches)
5186
I I
11A I
FOA
i
I C
I
I .50
I *1.0
5186
I I
11B I
FOA
I
I C
I
I .50
I *1.0
5186'
I I
11C I
FOA
I
I C
I
I .50
I *1.0
5186
I I
I -lA I
I
I SG
I
I .5
I
I *1
5186
I
I --1A I
FOA
I
I DSB
f
I .50
I
*1.0
5186
f
I -1A f
FOA
I
I W
I
I .50
I
*1.0
5186
I I
I -113 I
I
I SG
I
I .5
I *1
5186
-V12
FOA
I DSB
I .50
I *1.0
I
5186
I -1B I
FOA
I W
I
I .50
I *1.0
5186
I I
I -1C I
I SG
I
I .5
*1
Page: 8

ANIMAL WASTE UTILIZATION PLAN
5186
5186
FOA
FOA
DSB
.50
*1.0
W I .50 $ *1.0
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations, the application amount shown cannot
be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180.00 days of temporary storage and
the temporary storage must be removed on the average of once every
6.00 months. In no instance should the volume of the waste be stored
in your structure be within the 25 year 24 hour storm storage or one
foot of freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility -of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply the
correct rates to the acres shown in Tables 1 and 2. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may
make this plan invalid.
Call your technical specialist after you receive the waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate prior to applying the waste.
NARRATIVE OF OPERATION
THIS PLAN IS WRITTEN ON AN TWO YEAR ROTATION WITH AN WETTABLE ACRE FOOTPRINT.
Page: 9

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
5. Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is.
danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
S. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be considered.
Page: 10

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to
wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly into water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
the site.
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation.' Vegetation such as trees, shrubs, and
other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 11

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
18. If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22. waste shall be tested within 60 days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when these
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be
maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North
Carolina regulations.
Pages 12

ANIMP;L , WASTE `UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm:M&M FARMS
Owner/Manager Agreement
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
North Carolina Division of Water Quality (NCDWQ) before the new
animals are stocked. I (we) also understand that there must be no
discharge of animal waste from this system to surface waters of the
state from a storm event less severe than the 25-year, 24-hour
storm. The approved plan will be filed on -site at the farm office
and at the office of the local Soil and Water Conservation District
and will be available for review by NCDWQ upon request.
Name of Facility Owner: MARTY BLIZZARD
(Please print)
Signature: Date: -.2-2 �dd
Name of Manager(I different from owner):
Signature:
Date:
Name of Person Preparing Plan: (Please print) JOHNNY L . LANIER
Affiliation:DUPLIN SOIL AND WATER CONSERVATION DISTRICT
Phone No. 910-296--2120
Address (Agency): PO BOX 219
KENANSVILLE NC 28349
Signature:L.,Date: a D
Page: 13

•" --^•7i 7` I iA., 7X6
i ,Al ,h�b,(y\+f.,
CI
r�,'r,�tfi' ��-r•� 3�y��rj:, r i w. y. W�.��i r �wc•. �'�',� �r,��e Y "' a
Farm Number (Identification) 3 n:•�. ti:Z eld-Burnow
;•� 'r; .{A y�` �''�'{�a .�a��rr-f 7;i_'y•,ju,.,:.,a�.i�i��
F. ,� r ����"`��l.... �k+ y. ,��h:i�w••Y.,fa'.'S• '4.�A:iN '�7
2. Irrigation System Designation cNE�usbng Imy gallon Systemrr tt rNewl E�rpandedmgation
w i = - . - V.yt iY�,• S!`l Stitch S 1 4 ~_ X Y 6, '�.e.' Y Vl1 1, i ,may,,,
iz d -Q.,•n !' .� ir'� 5'L 'S'i 'G�;! >..W k '��IT
3. Number of Travel Lanes ' #Interior Lanes # Extenor`I;anes S a feet] Length of pull )
# Interior Lanes # Exterior Lanes feet Len h¢of ull`
# Interior Lanes ,t L _ # Exterior Lanes G 5 feet] Length of pull
4. Wetted Diameter �29'0_ [feet] From field data sheet
5. Spacing p D Hydrant Spacing [feet] _ 7 / [as percent of wetted diameter]
6, Hydrant Layout ,./ Multiple Hydrants - Single Hydrant Excessively spaced Hydrants
7. Read the irrigated area per travel pull for the given wetted diameter from the appropriate table and column
based on pattern, spacing, and travel lane location.
Travel Lane Length (Li) Interior or 1 A Exterior (Lane/Hydrant)
q. (a) Acres start end of pull from Table Kc 8-s" Column.
8;L (b) Acres middle portion of pull (L1)
{Pull Length SGO [feet] X Wetted Width 1,2 0 [feet]) / 43,560
� o (c) Acres stop end of pull from Table tE a Column C.
_3 ;L4 Total acres for Travel Lane Length (LI) (Sum: a + b + c)
Travel Lane Length (L2) JP_ Interior or Exterior (Lane/Hydrant)
3 (a) Acres start end of pull from Table EL 7 a Column �r
�g 0 (b) Acres middle portion of pull (L1)
{Pull Length_ [feet] X Wetted Width ,% Qa [feet]) / 43,560
O _ (c) A;res stop end of pull from Table Ez- to Coli:rnn _ • C
Total acres for Travel Lane Length (L2) (Sum: a + b + c)
Travel Lane Length (L3) Interior or [ Exterior (Lane/Hydrant)
U X. (a) Acres start end of pull from Table f t 83" ColurrM g
;L, 9 (b) Acres middle portion of pull (L1)
{Pull Length LS► [feet] X Wetted Width gaD [feet]) / 43,560
0 (c) Acres stop end of pull from Table Et Iss Column c-
_ Total acres for Travel Lane Length (L3) (Sum: a + b + c)
8. Multiply the tabulated irrigated acreage value per travel pull by the number of pulls of each category in the
field. Sum all of these and this is the total irrigated acreage for the field.
3� (a) Acres per Travel Lan. -Length (L1) X I Lanes = 3. y Acres
,3. , IS - (b) Acres per Travel Lane Length (L2) X _ rr Lanes - 3�1s' Acres
3, 71 (c) Acres per Travel Lane Length (L3) X - - ;� Lanes - 3. 7 1 Acres
Total CAWMP Wettable Acres for field (Sum: 8a + 8b + 8c)
Wettable Acre Computational Worksheet Completed by: Date:9%

3,ca.
CAWMP v
S. 1s•,�,i , 1T }-.vr�lt�e�,iiti rd�-:.i- y�4t r q� a :K
{� .�; Traveling Gmi Fi�eyld Data si�ee� y2,0�
' } }'.. �•". � L c ,X'�.,n i:, � r 'i vc L s' J � ,. r r,., .. •, eq.`:Y tiy'cj . fi+v.e,• r N3 ✓�k�rr,.( s� �h � 3"q a •il � �;�* t._ r� .y,�5_ r
_ '^ •4'A Yu+.;.;G. sih*PA`..�,,.a'�s,•.w3,,:.i-"•34.11'�1'i5+"FY'y�- + ss i u• y 5.� '�h3 a ;1
,�Hard;Hose ,Traveling GunSystem,R 4 •, 4
.d` i.e. �.. f,.
FIELDDATA'SHEET�*
• , ��` _ . =J_ • r} j'' - � f J r ,�+`r• Yam: rl. rlV 1�'ti S R CC�R Y,�`.�k[-svG• 1
i. Make and model number 2S`�.
2. Hose length0 feet and hose.inside diameter � ] (JD) , S [inch]
36 Gun make and mode! number S�A,
4. Gun nozzle size _ , �� [inch], ring orifice, taper bore orifice.
5. Gun arc angle 3 3 O [degrees]
6. Travel Iane spacing r20 f7 [feet]. Indicate whether uniform, random.
Number of exterior hydrants _ �2, Number of interior hydrants 4 .
�d� 4, '•�f.�
d{cis
!. , oet.�J ?�'N}7,j�r �. ..� �.'�if�F•7]S!j'I
7. Gun wetted diameter [feet]. measured, based on gun chart.
8. Gun pressure `des (psi]. _�� observed at working gauge,
determined from gun charts, calculated (show calculations)
**9. Operating pressure at hose reel rO.S' [psi]. observed at working gauge,
< provided by owner.
** 10, Supply line sized [inch] (from pump to last hydrant).
* * 11. Supply line length In feet (maximum pumping distance).
* * 12. Supply line type PVC, _aluminum.
* * 13. Pump make and model number
'* 14, Pump capacity, (gpm].
** 15. Engine make and model number
or
** 16. Electric motor horsepower and rprr. [hp] [rr;m]
Note: It is strongly recommended that operating pressure at the reel and gun wetted
' . 'diameter be field detemn ned.
* Locate each hydrant on a copy of the map_ Indicate the start and stop of the sprinkler car
for each travel lane and show distan:e traveled. Show_ the location of the supply line.
Irrigated acres will be determined by travel lane
Optional data, furnish where possible.
**" Info -oration furnished by
and/or �..J
Signature f Ovner 4tacifity Representative Si tune of Technical Specialist
Printed Name- of Owner or Facility Representati•: c Printed naive of Technical Specialist
Date 21,2o f o Date oel
* * * Only the person or persons collecting the data should sign the data sheet.

000v�
t
A i /
::... �.�.. 99 9 # bail
':4 09Z = 40ui �
8Z8- Lc # wie:i piezzli8 A:peW

WETTABLE ACRES
IRRIGATION SYSTEM DESIGN PARMATERS
and
COMPUTATIONAL WORKSHEET SUMMARY
Landowner/ Operator Name Marty Blizzard
Adress 141 N Blizzard Town Rd
Beulaville NC 28518
Telephone [phone]
TABLE 1 - Field Specifications
COUNTY IDupiin
DATE 9/27100
Tract
Number
Hydrant
or
field (1)
Number
acres
start end
wetted
area
acres
middle
wetted
area
acres
stop end
wetted
area
Apprwdmate
Maximun
Useable Sias
of field (2)
(acres)
Table
column
Length
of
pulls
in feet
Width
of
pulls
in feet
Sail Type.
Slope
(%)
Crop(s)
Ma)dmun
Application
Rate (3)
(infhr)
Ma)dumn
Application
per Irrigation
cycle (3)
(inches)
5186
1A
0.42
2.82
0
3.24
EE85
B-C
560
220
FOA
0-5
CORN 1 WHEAT 1 SOYBEAN
0.5
1
5186
18
0.35
2.8
0
3.15
E170
B-C
610
200
FOA
0-5
CORN I WHEAT 1 SOYBEAN
0.5
1
5186
1C
0.42
3.29
0
3.71
EE85
B-C
651
220
FOA
0 5
CORN 1 WHEAT 1 SOYBEAN
0.5
1
1 see attached map.
2 Total field acreage minus required buffer areas.
3 Refer to N.C. Irrigation guide, Field Office Technical Guide, Section 11 G. Annual application must not exceed the agronomic rates for the soil and crop used.
Wettable Acre Computational Worksheet Completed by: Date

k�7
Animal-,
nim l,Waste Management Plan .Ce`rti 64tion -
{Please. or'print all information that does noi,require�natur`e) '
_ yr• N � � 4,; �'. r k ��a � •y �. ^ ,
-•:• }.4.};. t_:,-.�-_•?'p$i�f. /r!.^"Tti-- Y.:'a�iF oz.�.... t�uikrrn,?2��-:�.... ram-2!:Y �.�fSei4: ae 4Ji* •11^?�`: a�J.{'..ea .. �.. e.. r.. .....a�...F.�..4�MLMe%iar wi{vYi?:I.2..'.•1--}v. +•,G'e`Y�S .....z..•L; ri'.
General 1'nformation:. ;
Name of Farm: MAfM 8.122 AM:> Nsz , -Facility No: -
Owner(s) Name: 1K^ i=86D hone No: -gj'o — 4zs-t
Mailing Address:._ A H. BLr2ZA Q_-M WPt ROAM BS/ a
Farm Location: Fourteen Digit Hydrologic Unit:__ o3c.3oo,*70 46o i a
Latitude and Longitude:3-� 5--L AQ_�d / 7Z 4q ; Q4-!k,! County: 3-'wo-oK _
Please attach a copy of a county road map with location identified and describe below (Be specific: road -
names, directions, milepost, etc.): Alkbx. ¢ mllas W F e pN
f� M F ..T vr�.Q 6cT' vv [ .SQ rToz . l=s�QM zs L o to rc D I!
Operation Description:
Type of Swine No. of Animals
&Wean to Feeder , _;=Z __
O Feeder to Finish
O Farrow to Wean
0 Farrow to Feeder
Ct Farrow to Finish
Type of Poultry
0 Layer
0 Pullets
No. of Animals
Type of Cattle No. of Animals
0 Dairy
Cl Beef
kl�w/ems
Other Type of Livesrack: e'xrsr 0 Number of Animals:.29�a
Acreage Available for Application: 10 + Required Acreage: . „10
Number of Lagoons / Storage Ponds: I Total Capacity: 175, Soo Cubic Feet (ft3) .
- 4Posy ise-0- — F_) eC ""-
Are subsurface drains present on the farm: YES or - NO (please circle one) TPwr4cH 60.0w' &,,per-z rmz
******************************************************************r***************** but
Owner / Manager Agreement' ,
I (we) verify that all the above information is correct and will be updated upon changing. I (we) understand the operation and
maintenance procedures established in the approved animal waste management plan for the farm named above and will
implement these procedures. I (we) know that any expansion to the existing design capacity of the waste treatment and
storage system or construction of new facilities will require a new certification to be submitted to the Division of
Environmental Management before the new animals are stocked. I (we) understand that there must be no discharge of animal
waste from the storage or application system to surface waters of the state either directly through a man-made conveyance or
from a storm event less severe than the 25-year, 24-hour storm and there must not be run-off from the application of animal
waste. I (we) understand that run-off of pollutants from lounging and heavy use areas must be minimized using technical
standards developed by the Natural Resources Conservation Service. The approved plan will be filed at the farm and at the
office of the local Soil and Water Conservation District. I (we) know that any modification must be approved by a technical
specialist and submitted to the Soil and Water Conservation District prior to implementation. A change in land ownership
requires written notification to DEM or a new certification (if the approved plan is changed) within 60 days of a title transfer.
Name of. Land Owner : N f r Y __& Lz Z If 0
Signature: GL'7. �� Date: 1 G - �l
Name of Manager(if fferent from owner):
Signature: Date:
AWC -- April 24, 1996 1

. 'e inicaI;S}�J�ecialist C,ertif
+ ' i
� ai.� .{ � . -, � - wF . Co-"
' , Kr
I.+ As a'te'dhnicia specialist designated bythe North Carolina Soil and.Wate"r C&i6vanon Commission
pursuant to ' 15A' NCAC 6F``.0005; I cer f, .'that the- animal waste �tnanagertmertt'systcrii for the farm
named above has an animal,wpte management plait that meets of,exceeds standards and specifications
of the Division of Environmental Management (DEM) as' specified in 15A .NCAC• 2H.0217 and the
USDA -Natural Resources Conscrvadon Seivtce..(NRCS) and/or the Noith..Carolina Soil arid Water
Conservation Commission pursuant to 15A NCAC 2H.0217 and 15A' NCAC "6F .0001-.0005. The -
following elements are included in the plan as applicable. While each category designates a technical'
specialist who may sign each certification' (SD, SI, WUP, RC, 1), the technical specialist should only'
certify parts for which they are technically competent.
IL Certification of Design
A) Collection. Storage. Treatment ,System
Check the approphare box
Cl Existing facility; twt hout re t (SD or WUP)
Storage volume is adequate for operation capacity; storage capability consistent with
waste utilization requirements.
New, expanded or retrofitted_facility (SD)
Animal waste storage and treatment structures, such as but not limited to collection systems,
lagoons and ponds, have been designed to rrlgst'or exceed the minimum standards and
specifications. ,+ ' '' 'r•
Name of Technical Specialist (Please Print)- :> .;'id'°'A;..�s-„ , „_,_•
Affiliation:
Address(Agency):
Signature: Date: in l rPf 9C
B) Land Application Site (WUP) a''Of:C� YD
The plan provides for minimum separations ( ufi`ers); adequate amount of land for waste
utilization; chosen crop is suitable for waste management; hydraulic and nutrient Ioading rates.
Name of Technical Specialist (Please Print): A6 Ale-&56
Affiliation: CAQVlL.s Jo,M, .Tic
Address(Agency): 0�0.&x S5-6 sg_" , N- C' ;2s398 Phone No.. Q/O 293 ��435t—
Signature: Date: ial RZoig
C) Runoff Controls from Exterior Lots N/A
Check the appropriate box
O Eggility without exterior lots (SD or WUP or RC)
This facility does not contain any exterior lots.
© Facility with exterior lots (RC)
Methods to minimize the run off of pollutants from Iounging and heavy use areas have been
designed in accordance with technical standards developed by MRCS.
Name of Technical Specialist (Please Print):
Affiliation:
Address(Agency): Phone No.:
Signature: Date:
AWC -- April 24, 1996 2

D) Appjic ion and IIantllm .yuioment 5e� A .+c►�inr +— A (\/� ,Y .
Check the, approprsaie bo. _` } J7.r, '
ZI Existing facili 'wuh existing waste a taJca" "'Cqurriinent
'.�
Animal waste application equipment specified in thc'plari tias.,been;either field calibrated or
* r1•Y "};
evaluated in`accordarice with existing desigri,.charts and tables and is able to'apply,waste as .
necessary to accomrriodaie the waste management plan: (existing application equipment ca:n
cover the'area'•required by the plan at'rates not to exceed either cite specified hydraulic or
nutrient loading rates, a schedule for timing of applications has laeeii established; required
buffers can be maintained and calibration and adjustment guidance are'contained as part of the
plan).
Q/ New or expanded facility: or existing facili v without existing waste application equipment (I)
Animal waste application equipment specified in the plan has been designed to apply waste as
necessary to accommodate the waste management plan; (proposed application equipment can
cover the area required by the plan at rates not to exceed either the specified hydraulic or
nutrient loading rates; a schedule for timing of applications has been established; required
buffers can be maintained; calibration and adjustment guidance are contained as part of the
plan).
Name of Technical Specialist (PIease Print): a
Affiliation: e2.dkousJ�oils
Address(Agency):.Z.o..Bo,c S56 /,t/•41JgKl. lY. c 2s398 Phone No.:ALo34-
Signature: .)a. g _ Date: .P,1S_1?6
III. Certificafion of Installation
A) Collection,, Storage. Treatment installation
New, expanded or retrofitted facility (SI)
Animal waste storage and treatment structures, such as but not limited to lagoons and ponds,
have been installed in accordance with the approved plan to meet or exceed the minimum
standards and specifications.
For existing facilities without retrofits, no certification is necessary.
Name of Technical Specialist (Please Print): 11,VMAeQ &6.5.0t4
Affiliation: 0,44
c?s arc•
Address (Agency): 00. BD►c E56 , W...e_T t,u A( C. Ag_3? ,a Phone No.:0/o ;293 -3¢�
Signature:_ Lr1� d Date: 10 _ 7. 3 -9; - _
AWC -- Aprit 24, 1996

B) Land AnoliSite..(Nc�u
P)
Check'.rhe appropriate boz. - r
• The cropping system,is in place on all land as specified in the animal waste management plan.
O Conditional Approval: all required land as specified in the plan'is cleared for planting; the
cropping' system as specified in the waste utilization plan has not been,established and the `
owner has committed to establish the vegetation as specified in the plan by
(month/day/year); the proposed cover crop is appropriate for compliance with the waste
utilization plan.
O Also check this box if appropriate
if the cropping system as specified in the plan can not be established on newly cleared
land within 30 days of this certification, the owner has committed to establish an interim
crop for erosion control;
Name of Technical Specialist (Please Print):_ _.4 W ARD AP-B,Sa N
Affiliation: .eo' oeOons c .
Address(Agency): _�&ox AM, /A1•9•e'3Aw, ,A( C. �?-e32.8 Phone No.: _o_ ;29.f-391- -
Signature:
This following signature block is only to be used when the -box for conditional approval in III. B
above has been checked.
I (we) certify that I (we) have committed to establish the cropping system as specified in my (our) waste
utilization plan, and if appropriate to establish the interim crop for erosion control, and will submit to
DEM a verification of completion from a Technical Specialist within 15 calendar days following the date
specified in the conditional certification. I (we) realize that failure to submit this verification is a
violation of the waste management plan and will subject me (us) to an enforcement action from DEM.
Name of Land Owner:
Signature: Date:
Name of Manager(if different from owner):
Signature: Date:
C) Runpff Controls from E,sgrior Lots (RC) A�
Bicilily with extgrior lots
Methods to minimize the run off of pollutants from lounging and heavy use areas have been
installed as specified in the plan.
Forfacilities without exterior lots, no certification is necessary.
Name of Technical Specialist (Please Print):
Affiliation:
Address (Agency): Phone No.:
Signature: Date:
AWC -- April 24, 1996 . 4

D) AlIblicatWd and HandlinQl : {lmment installation (WUPor i) i
1'K` .6-. i ../A '[., n•` 1 T r�vc.ht M1 �JY .1' ,�'[ •t'VR, �j y 4�^� . .
Cheek ihe`appropriateblock
Ar'x •� •. 4r n'r� _, r 11i_ .t• r'S a.s r ;, -�, k s',+. _` �,1. /.'
0 Anurml"wasie application and handling equipment specified in the pladi on"site and ready
for use; calibration and adjustment`• riiaierial5 have been provided to the owners and are
contained as part of the plan. ^
Animal waste application and handling equipment specified in the laa has not been
installed but the owner ha —proposed leasing or third parry application and has provided a
signed contract; equipment specified in the contract agrees with the requirements of the
plan; required buffers can be maintained; calibration and adjustment guidance have been
provided to the owners and are contained as part of the plan.
a Conditional approvalAnimal waste application and handling equipment specified in the
plan has been purchased and will be on site and installed by
(month/day/year); there is adequate storage to hold the waste until the equipment is. installed
and until the waste can be land applied in accordance•with the cropping system contained
in the plan; and calibration and adjustment guidance have been provided to the owners and
are contained as part of the plan.
Name of Technical Specialist (Please Print): 41.mgp f{&BsvAt
Affiliation: Z?AAeca s Goas. rNc.
Address (Agency): 8 Phone No.:_9ra-ZY3-fJt3V-
Signature: Z,�l Date: �Ls�6
The following signature block is only to be used when the box for conditional approval in HI D
above has been checked.
I (we) certify that I (we) have committed to purchase the animal waste application and handling
equipment as specified in my (our) waste' management plan and will submit to DEM a verification of
delivery and installation from a Technical Specialist within 15 calendar days following the date specified
in the conditional certification. I (we) realize that failure to submit this verification is a violation of the
waste management plan and will subject me (us) to an enforcement action from.DEM.
Name of Land Owner:
Signature: Date:
Name of Manager(if different from owner):
Signature: Date:
Please return the completed form to the Division of Environmental Management at the
following address:
Department of Environment, Health, and Natural Resources
Division Of Environmental Management
Water Quality Section, Compliance Group
P.O. Box 29535 •
Raleigh, NC 27626-0535
Please also remember to submit a copy of this form along with the complete Animal Waste
Management Plan to the local Soil and Water Conservation District Office and to keep a copy in
your files with your -Animal Waste Management Plan.
AWC -- April 24, 1996 5

CE
Animal
_i} Y � i. •'iE �` .5 i' ' ' i 1 ✓ � p�'ff� )ii f 3 A .t
WasfeManagement1P1An ,
Certifications
ATT . HMEN1 A
1161 .0 VXALAW1 '..1.
On May 1, 1996 the Soil and Water Conservation Commission voted to
delay the effective date of the new Natural Resources Conservation Services
(NRCS) Technical Standards from June 1, 1996 until September 1, 1996.
One of the main reasons for this decision was to allow addition time for the
technical specialist to incorporate these new standards into projects that are
currently being designed. Another reason was the need to allow time for
additional technical specialist to receive designation from the Soil and Water
Conservation Commission as Irrigation Specialist.
This delay allows a design to be certified under the current NRCS standards
until September 1, 1996. Since -PartH. D. of the Animal Waste Management
Plan Certification (Form AWC -- April 24, 1996) was based on the
requirements of NRCS's new standards, it may not be appropriate for all new
or expanded facility; or existing facility without existing waste application
equipment.. Therefore this Attachment has been developed for those cases
when the level of design meets the requirements of the current standards but
does not meet the level of detail that will be required by the new standards.
While it is not a requirement, it is strongly encouraged that the design follow
the new standards and be certified by a technical specialist with a
designation as an Irrigation Specialist. In those cases, the certification in
Part II. D. would be appropriate and this attachment would not we used.
This Attachment will not be acceptable past the effective date of the new
NRCS Technical Standards.

' • • "�1n ' yet' 3 L�,r.. i
Anillnal .Waste Managelment PlaFn Certification '
ATTACHMENT A
FORM Awt'_-- APR1L 24. L946
Name of Farm: Mom. jj zLAen N 92 Facility No:
Owner(S) Name:wg ni B-4�51e
Mailing Address: ,4V 8&zmn-7,o-wN R�aa, egaAkze At 286,,,9 �,-
IL Certification of Design Worn: mol &wmt 9AS WAISM AZDM JE4W7,V4::
S4RM CUs7*lf -:V%ED FY C/1jL de; 8,9(obe;
wr7W 7T�1 E&#1C CoN /& {�G4,�ls 70 6,O&riA1UE
D) Application and Handling„Equipment . ms wrm d,�w x;w, ,4(,..
New gr e Fanded facility: or existing facility without exisring waste application
(WUP or I)
Animal waste application equipment specified in the plan has been either field
calibrated or evaluated in accordance with existing design charts and tables and
is able to apply waste as necessary to accommodate the waste management plan:
(application equipment can cover the area required by the plan at rates not to
exceed either the specified hydraulic or nutrient loading rates, a schedule
for timing of applications has been established; required buffers can be
maintained and calibration and adjustment guidance are contained as part of the
plan).
Name of Technical Specialist (Please Print): W",
Affiliation: ehtPacc� T--azys.
Address(Agency):�Do. e- wA,c 6 Phone No.:qto-z93- 34-34-
Signature: c:�L,)a Q 44— Date: r YZ
If the technical specialist chooses to use this Attachment to certify the design of a
new or expanded facility; or existing facility without existing waste application
equipment, it must be attached to the completed Animal Waste Management
Certification Form (AWC- April 24, 1996). The technical specialist must also write
in the words "See Attachment" in Part II. D. of the Certification Form to notify the
review agencies that the Attachment has been used.
This Attachment will not be acceptable past the effective date of the new NRCS
Technical Standards.
AWC(A) -- May 3, 1996

Of
or v
.� yr. � _ + t � �� r..q ♦ � a � Y
'ar
~ G
y y
e' �
s, F LIf
C t
1 PC t'
d Fr
tai : a pp p v c
C 1.1
r�l it ig to 'if ! 1�
1
0 @_
TA
_ § m IA
is ti k
CL
it
00
ca
0 co
co wl
O + •�
P i2i
3 F '+ 4f is'r'" + i. r y i � 3Y •; � i7 Skr ' i,.:�� PI �.
44� �� doss � � �,.t "}r:{r. � � '+''a' _ � y` r�• .n _ - • .
1 �, '� t•� t '4-v'� - y f( •s - +'1 � r � �"r Fe. fl r� S , -� r [ / �' _ r
is �619 Y� i• °� _,'�~ rr r 11. S r S .[ r` S� f Ci� � r ,.. �' � � J G '!4 • _ . _�,\ �

.
..,INSEC.T_ CONTROL CHECKLIST
F L
17-0R-ANIMAL_OPER_ ATLONS_
, Zi tI _ e.i., •�.���y,. 5
Source t' `StCaust:'�i ="�Uw <'z;-ar :-:�Mrrrt! "'��� BMP's to Minimize Odor Site Specific Practices.
.. Jr jquld Systems)
Flush Gutters Accurrwlatioh of solids "� 'z
' ' (Utdssh system is designed and operated
._^sufficiently to remove accumulated
mild from gutters as designed.
.
( emove bridging of accumulated solids at
discharge
Lagoons and Pits Crusted Solids
(),ntain lagoons, settling basins and
pits where pest breeding is apparent to
minimize the crusting of solids to a depth
of no more than 6.8 inches over more than
30% of surface.
Excessive Vegetative Decaying vegetation
( aintain vegetative control along banks of
Growth
lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along water's edge on impoundment's perimeter.
(Dry Systems)
Feeders Feed Spillage
() Design, operate and maintain feed systems (e.g.,
bunkers and troughs) to minimize the accumulation
of decaying wastage.
(} Clean up spillage on a routine basis (e.g. 7-10 day
interval during summer; 15.30 day interval during winter).
Feed Storage Accumulations of feed residues
I) Reduce moisture accumulation within and around
immediate perimeter of feed storage areas by
insuring drainage away from site and/or providing
adequate containment (e.g., covered bin for
brewer's grain and similar high moisture grain
products).
() Inspect for and remove or break up accumulated
solids in filter strips around feed storage as needed.
Animal Holding Areas Accumulations of animal wastes
() Eliminate low area that trap moisture along fences
and feed wastage
and other locations where waste accumulates and
and disturbance by animals is minimal. '
() Maintain fence rows and filter strips around animal
holding areas to minimize accumulations of wastes
(i.e. inspect for and remove or break up accumulated
solids as needed).
AMIC--November 11, 1996

- SWINE FARM WASTE M
• — . W•. � . ..,'fit 'r: t
►DEMENT ODOR CONTROL=;CHECKLIST.vd'�n ,.,„kr►�.• t .
Source
Cause �`SM�''s to'Minimize Odor' $"�{` �' �"� '�Y Site Speclftc Practices
Y �i!�t� In '+R7ri:n" s'll �:'.➢lR�{tlM,WTt �+ Skio;-3tiJ':hP•!P31i 'IYI]d�:V'f'l1'yfXi9tfF'!•� . `', Yh •r•"„'�'.•
Farmstead
Swine production t;, . v *3• "u 3u + of 'I:[ a atative or wooded buffers;
best management ' _
ecommanded
rlsl:U_ cw n �, l IVW; f T !::!' Cq Yp�tl7 I x3o� rs ; i`•a3 .ua.,ir t, a a,is,Y,l!s�c
,r
practices;
4e-
f ood judgment and common sense
Animal body surfaces
Dirty manure -covered animals -- O floors -- - - -
Floor surfaces
Wet manure-coverad.floors { ott�ed floors;
{ I Wa erers located over slotted floors;
{) Feeders at high and of solid floors;
{ )Scrape manure buildup from floors;
I 1,44erfioor ventilation for drying
Manure collection pits
Urine ( requent manure removal by flush,pit
recharge,or scrape
Parital micorbial decomposition ( erfloor ventilation
Ventilation exhaust fans Volatile gases; li'Fan maintenance;
Dust I Icient air movement
Indoor surfaces Dust (ashdown between groups of animals
{) Feed additives;
() Feeder covers;
I } Feed delivery downspout extenders to
feeder covers
Flush tanks Agitation of recycled lagoon
{) Flush tank covers
liquid whiles tanks are filling
{ I Extend fill lines to near bottom of
tanks with anti -siphon vents
Flush alloys Agitation during wastewater
U-11nde'rfloor flush with underfloor
conveyanance
ventilation
Pit recharge points Agitation of recycled lagoon I ) Extend rechard lines to near bottom of
liquid while pits are filling pits with anti -siphon vents
Lift stations Agitation during sump tank filling () Sump tank covers
and drawdown
Outside drain collection Agitation during wastewater f } Box covers
or junction boxes conveyance
End of drainpipes at lagoon Agitation during wastewater TTExtand discharge point of pipes
underneath lagoon liquid level
Lagoon surfaces Volatile gas emissions { roper lagoon liquid capacity
Biological mixing { orroct lagoon startup procedures
Agitation ( inimum surface area -to -volume ratio
Imum agitation when pumping
() Mechanical aeration
() Proven biological additives
Irrigation sprinkler nozzles High pressure agitation ( Agate on dry days with little or no wind
Wind draft ( inimum recommended operation pressure
ump intake near.lagoon liquid surface
{) Pump from second -stage lagoon
AMOC--November 11, 1996
t

•EMERGE_ NCY ACTIONTL#AN
.egtyaal it z1:NQN, UM,BERSrC e,ff Ir 1. 4x9' enr i i,4,4A. ,'< .(Z
DIVISION OF WATER QUALITY (DWQ)„;ta,6,r , , r� � , • �. r: (9;� 0}395;3904..
EMERGENCY MANAGEMNETt.,SERV_,ICEsf(EMS),F ���� �,�� v,r,� .�; (9.10)296.421'60
SOIL�AND,fWATER ;COIVSERVATION1DISTRICTI(SWCD) ;;::�� ,� r� ; (9�;10)29fi-29.20�
NATURAL' RESOURCES CONSERVATION'SERVICEt�NRCS)�.�;_�, 1lif(91.0)296:,2121''
COOPERATIVE EXTERSION SERV,ICEI(CES)r F�::`; .-let )�tj ,ta;Fl t ,: � s(910)29fi-2143
��`;r;1.' ;i;�"iJ«x ..r,.��,�� •,,•� lit n,f;;
This plan will be implemented in the event that was. -tesIi":t from ,your, operation ,are leaking,
overflowing or running off site. You should not wait -until .wastes reach surface waters
or leave you property to consider that you have a problem. You should make every
effort to ensure that this does not happen. This plan should be posted in an accessible .
location for all employees at the facility. The following are some action items you should
take.
Stop the release of wastes. Depending on the situation, this may ore may not be
possible. Suggested responses to some possible problems are listed belwo.
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B. Runoff from waste application field -actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that cause the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinklers -action include:
P3
a. Stop recycle pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
Leakage from flush systems, houses, solid separators -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure siphon occurs.
d. Stop all flows in the house,
flush systems, or solid separators.
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed
to flowing leaks -possible action:
a. Dig a small sump or ditch from the embankment to catch all
seepage, put in a submersible pump, and pump back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon
bottom as soon as possible.

• , r.77y�y r�,f a ��st' `+e. F-• `.a n , .`�
.,4
r .
System Calibration = ,
1•
. 3
Information presented in manufacturer's charts are based-bn',average,operaton_ ,
conditions with relatively new equipment. Discharge rates'and'application rates
change over as equipment gets older and components wear.'w'In particular;"
pump wear tends to reduce operating pressure and flow: With continued use,
nozzle wear results in an increase in the nozzle opening which will increase the
discharge rate while decreasing the wetted diameter.
You should be aware that operating the system differently than assumed in the
design will alter the application rate, diameter of coverage, and subsequently the
application uniformity. For example, operating the system with excessive pressure
results in smaller droplets, greater potential for drift, and accelerates wear of the
sprinkler nozzle. Clogging of nozzles can result in pressure increase. Plugged
intakes or crystallization of mainlines will reduce operating pressure. Operating
below design pressure greatly reduces the coverage diameter and application
uniformity.
For the above reason, you should calibrate your equipment on a regular basis to
ensure proper application rates and uniformity. Calibration at least once every
three years is recommended. Calibration involves collecting and measuring flow at
several locations in the application area. Any number of containers can be used to
collect flow and determine the application rate. Rain gauges work best because
they already have a graduated scal-e from which to read the application amount
without having to perform additional calculations. However, pans, plastic buckets,
jars, or anything with a uniform opening and cross-section can be used provided
the liquid collected can be easily transferred to a scaled container for measuring.
For stationary sprinklers, collection containers should be located randomly
throughout the application area at several distances from sprinklers. For traveling
guns, sprinklers should be located along a transect perpendicular to the direction of
pull. Set out collection containers 25 feet apart along the transect on both sides of
the gun cart. You should compute the average application rate for all
nonuniformity of the application. On a windless day, variation between containers
of more than 30 percent is cause for concern. You should contact your irrigation
dealer or technical specialist for assistance.
*Reprinted for Certification Training for Operations of Animal Waste Management Systems Manua!
v:r

J. A -w
MORTALITY MANAGEMENT,:METHODS
(check which'method(s) are being.implemented) ' �µ.:�► '.;
( 1 Burial three, feet beneath the surface of the ground within 24 hours
after knowledge of the death. The burial be at least 300 feet from
any flowing steam or public body of water.
( "} Rendering at a rendering plant licensed under G. S. 106-168.7
( ) Complete incineration
{ ) In the case of dead poultry only, placing in a disposal pit of a size and
design approved by the Department of Agriculture.
] Any method which in the professional opinion of the State
Veterinarian would make possible the salvage of part of a dead
animal's value without endangering human or animal health. (Written
approval of the State Veterinarian must be attached)

R
OPERATION & MAINTENANCE PLAN
Proper lagoon liquid management should be a year-round priority. It is especially
important to manage levels so that you do not have problems during extended rainy and
wet periods.
Maximum storage capacity should be available in the lagoon for periods when the
receiving crop is dormant (such as wintertime for bermudagrass) or when there are
extended rainy spells such as the thunderstorm season in the summertime. This means
that at the first signs of plant growth in the later winter/early spring, irrigation according to
a farm waste management plan should be done whenever the land is dry enough to
receive lagoon liquid. This will make storage space available in the lagoon for future wet
periods. In the late summer/early fall the lagoon should be pumped down to the low
marker (see Figure 2-1) to allow for winter storage. Every effort should be made to
maintain the lagoon close to the minimum liquid level as long as the weather and waste
utilization plan will allow it.
Waiting until the lagoon has reached its maximum storage capacity before starting to
irrigate does not leave room for storing excess water during extended wet periods.
Overflow from the lagoon for any reason except a 25-year, 24-hour storm is a violation of
state law and subject to penalty action.
The routine maintenance of a lagoon involves the following:
Maintenance of a vegetative cover for the dam.
Fescue or common bermudagrass are the most common vegetative
covers. The vegetation should be fertilized each year, if needed, to
maintain a vigorous stand. The amount of fertilizer applied should be
based on a soils test, but in the event that it is not practical to obtain
a soils test each year, the lagoon embankment and surrounding areas
should be fertilized with 800 pounds per acre of 10-10-10, or
equivalent.
Brush and trees on the embankment must be controlled. This may be
done by mowing, spraying, grazing, chopping, or a combination of
these practices. This should be done at least once a year and
possibly twice in years that weather conditions are favorable for
heavy vegetative growth.
NOTE: If vegetation is controlled by spraying, the herbicide must not be allowed to enter
the lagoon water. Such chemicals could harm the bacteria in the Iagoon that are treating
the waste.
Maintenance inspections of the entire lagoon should be made during the initial filling of
the lagoon and at least monthly and after major rainfall and storm events. Items to be
checked should include, as a minimum, the following:
Waste Inlet Pipes, Recycling Pipes, and Overflow Pipes ---look for:
1. separation of joints
2. cracks or breaks
3. accumulation of salts or minerals
4. overall condition of pipes

Lagoon surface ---look for:
I . - undesirable vegetative growth
2. floating or lodged debris
Embankment ---look for:
1. settlement, cracking, or "jug" holes
2. side slope stability ---slumps or bulges
3. wet or damp areas on the back slope
4. erosion due to lack of vegetation or as a result of wave action
5. rodent damage
Larger lagoons may be subject to liner damage due to wave action caused by strong
winds. These waves can erode the lagoon sidewalls, thereby weakening the lagoon dam.
A good stand of vegetation will reduce the potential damage caused by wave action. If
wave action causes serious damage to a lagoon sidewall, baffles in the lagoon may be
used to reduce the wave impacts.
Any of these features could lead to erosion and weakening of the dam. If your lagoon has
any of these features, you should call an appropriate expert familiar with design and
construction of waste lagoons. You may need to provide a temporary fix if there is a threat
of a waste discharge. However, a permanent solution should be reviewed by the
technical expert. Any digging into a lagoon dam with heavy equipment is a serious
undertaking with potentially serious consequences and should not be conducted unless
recommended by an appropriate technical expert.
Transfer Pumps ---check for proper operation of:
1. recycling pumps
2. irrigation pumps
Check for leaks, loose fittings, and overall pump operation. An unusually loud or grinding
noise, or a large amount of. vibration, may indicate that the pump is in need or repair or
replacement.
NOTE: Pumping systems should be inspected and operated frequently enough so that you
are not completely "surprised" by equipment failure., You should perform your pumping
system maintenance at a time when your lagoon is at its low level. This will allow some
safety time should major repairs be required. Having a nearly full lagoon is not the time
to think about switching, repairing , or borrowing pumps. Probably, if your lagoon is full,
your neighbor's lagoon is full also. You should consider maintaining an inventory of spare
parts or pumps.
Surface water diversion features are designed to carry all surface
drainage waters (such as rainfall runoff, roof drainage, gutter outlets,
and parking lot runoff) away from your lagoon and other waste
treatment or storage structures. The only water that should be
coming from your lagoon is that which comes from your flushing
(washing) system pipes and the rainfall that hits the lagoon directly.
You should inspect your diversion system for the following:
I. adequate vegetation
2. diversion capacity
3. ridge berm height

Identified problems should be corrected promptly. It is advisable to inspect your system
during or immediately following a heavy rain. If technical assistance is needed to
determine proper solutions, consult with appropriate experts.
You should record the level of the lagoon just prior to when rain is predicted, and then
record the level again 4 to 6 hours after the rain (assumes there is no pumping). This will
give you an idea of how much your lagoon level will rise with a certain rainfall amount
(you must also be recording your rainfall for this to work). Knowing this should help in
planning irrigation applications and storage. If your lagoon rises excessively, you may
have an inflow problem from a surface water diversion or there may be seepage into the
lagoon from the surrounding land.
Lagoon Operation
Startup:
1. Immediately after construction establish a complete sod cover on bare soil
surfaces to avoid erosion.
2. Fill new lagoon design treatment volume at least half full of water before
waste loading begins, taking care not to erode lining or bank slopes.
3. Drainpipes into the lagoon should have a flexible pipe extender on the
end of the pipe to discharge near the bottom of the lagoon during initial
filling or another means of slowing the incoming water to avoid erosion of
the lining.
4. When possible, begin loading new lagoons in the spring to maximize
bacterial establishment (due to warmer weather).
5. It is recommended that a new lagoon be seeded with sludge from a healthy
working swine lagoon in the amount of 0.25 percent of the full lagoon
liquid volume. This seeding should occour at least two weeks prior to the
addition of wastewater.
6. Maintain a periodic check on the lagoon liquid pH. If the pH falls below
7.0, add agricultural time at the rate of 1 pound per 1000 cubic feet of
lagoon liquid volume until the pH rises above 7.0. Optimum lagoon liquid
pH is between 7.5 and 8.0.
7. A dark color, lack of bubbling, and excessive odor signals inadequate
biological activity. Consultation with a technical specialist is recommended
if these conditions occur for prolonged periods, especially during the warm
season.
Loading:
The more frequently and regularly that wastewater is added to a Iagoon, the better the
lagoon will function. Flush systems that wash waste into the lagoon several times daily are
optimum for treatment. Pit recharge systems, in which one or more buildings are drained
and recharged each day, also work well.

Management:
Practice water conservation ---minimize building water usage and
spillage from leaking waterers, broken pipes and washdown through
proper maintenance and water conservation.
Minimize feed wastage and spillage by keeping feeders adjusted. This
will reduce the amount of solids entering the lagoon
Maintain lagoon liquid level between the permanent storage level and
the full temporary storage level.
Place visible markers or stakes on the lagoon bank to show the
minimum liquid level and the maximum liquid lever (Figure 2-1).
Start irrigating at the earliest possible date in the spring based on
nutrient requirements and soil moisture so that temporary storage
will be maximized for the summer thunderstorm season. Similarly,
irrigate in the late summer/early fall to provide maximum lagoon
storage for the winter.
The lagoon liquid level should never be closer than 1 foot to the lowest
point of the dam or embankment.
Do not pump the lagoon liquid level lower that the permanent storage
level unless you are removing sludge.
Locate float pump intakes approximately 18 inches underneath the liquid
surface and as far away from the drainpipe inlets as possible.
Prevent additions of bedding materials, long-stemmed forage or vegetation,
molded feed, plastic syringes, or other foreign materials into the lagoon.
Frequently remove solids from catch basins at end of confinement houses or
wherever they are installed.
Maintain strict vegetation, rodent, and varmint control near lagoon edges.
Do not allow trees or large bushes to grow on lagoon dam or embankment.
Remove sludge from the lagoon either when the sludge storage capacity is
full or before it fills 50 percent of the permanent storage volume.
If animal production is to be terminated, the owner is responsible for
obtaining and implementing a closure plan to eliminate the possibility of a
pollutant discharge.
Sludge Removal:
Rate of lagoon sludge buildup can be reduced by:

proper lagoon sizing,
mechanical solids separation of flushed waste,
gravity settling of flushed waste solids in an appropriately designed basin, or
minimizing feed wastage and spillage.
Lagoon sludge that is removed annually rather than stored long term will:
have more nutrients,
have more odor, and
require more land to properly use the nutrients.
Removal techniques:
Hire a custom applicator.
Mix the sludge and lagoon liquid with a chopper -agitator impeller
pump through large -bore sprinkler irrigation system onto nearby cropland;
and soil incorporate.
Dewater the upper part of lagoon by irrigation onto nearby cropland or
forageland; mix remaining sludge; pump into liquid sludge applicator; haul
and spread onto cropland or forageland; and soil incorporate.
Dewater the upper part of lagoon by irrigation onto nearby cropland or
forageland; dredge sludge from lagoon with dragline or sludge barge; berm
an area beside lagoon to receive the sludge so that liquids can drain back
into lagoon; allow sludge to dewater; haul and spread with manure spreader
onto cropland or forageland; and soil incorporate.
Regardless of the method, you must have the sludge material analyzed for waste
constituents just as you would your lagoon water. The sludge will contain different
nutrient and metal values from the liquid. The application of the sludge to fields will be
limited by these nutrients as well as any previous waste applications to that field and crop
requirement. Waste application rates will be discussed in detail in Chapter 3.
When removing sludge, you must also pay attention to the liner to prevent damage. Close
attention by the pumper or drag -line operator will ensure that the lagoon liner- remains
intact. If you see soil material or the synthetic liner material being disturbed, you should
stop the activity immediately and not resume until you are sure that the sludge can be
removed without liner injury. If the liner is damaged it must be repaired as soon as
possible.
Sludge removed from the lagoon has a much higher phosphorus and heavy metal content
than liquid. Because of this it should probably be applied to land with low phosphorus
and metal levels, as indicated by a soil test, and incorporated to reduce the chance of
erosion. Note that if the sludge is applied to fields with very high soil -test phosphores, it
should be applied only at rates equal to the crop removal of phosphorus. As with other
wastes, always have your lagoon sludge analyzed for its nutrient value.
The application of sludge will increase the amount of odor.at the waste application site.
Extra precaution should be used to observe the wind direction and other conditions which
could increase the concern of neighbors.

Possible Causes of Lagoon Failure
Lagoon failures result in the unplanned discharge of wastewater from the structure. Types
of failures include leakage through the bottom or sides, overtopping, and breach of the
dam. Assuming proper design and construction, the owner has the responsibility for
ensuring structure safety. Items which may lead to lagoon failures include:
Modification of the lagoon structure ---an example is the placement of a pipe
in the dam without proper design and construction. (Consult an expert in
lagoon design before placing any pipes in dams.)
Lagoon liquid levels ---high levels are a safety risk.
Failure to inspect and maintain the dam.
Excess surface water flowing into the lagoon.
Liner integrity -=-protect from inlet pipe scouring, damage during sludge
removal, or rupture from lowering lagoon liquid level below groundwater
table.
NOTE: If lagoon water is allowed to overtop the dam, the moving water will soon cause
gullies to form in the dam. Once this damage starts, it can quickly cause a large discharge
of wastewater and possible dam failure.

{ tSPC 2izS 1Q7
1
SWINE FARM
DESIGN, CONSTRUCTION, OPERATION,
AND MANAGEMENT PLAN
FOR
MARTY BLIZZARD
3552 WEAN TO FEEDER
June 19, 1996
I certify that this Plan has been prepared under my direct
supervision and meets the applicable regulations of
MRCS, DEM, and all other State and Local Regulations
to the best NNA0 e and belief.
��;' �ESSIo •• �y
M. Flo;d Adw P.T54 r Q -�

CARROLL'S FOODS, INC.
P. O. Drawer 856
WARSAW, NORTH CAROLINA 28398
FACILITY DESIGN AND
WASTE MANAGEMENT PLAN
Farm MARTY BLIZZARD
Name or Number
3552 NURSERY WEAN TO FEED EXPANSION
Farm Description
Location
DUPLIN COUNTY
Company Farm
Contract Grower X

4
SWINE FARM.
DESIGN, CONSTRUCTION, OPERATION,
AND MANAGEMENT PLAN
MARTY BLIZZARD
3552 WEAN TO FEEDER
TABLE OF CONTENTS
Lagoon Design Check List
Construction Information
Memorandum - Legal Requirements
Owner Contractor Information
Waste Management Facility Site Evaluation
Soil Investigation
Lagoon Design
Hazard Classification Data Sheet for Dams
Operation and Maintenance Plan .
Construction Specifications for Lagoons
Seeding Specifications
Plan for Lagoon
Typical Cross -Section of Lagoon
Volume Calculations
Waste Utilization Plan with Attachment B
Maps
A. Vicinity Map
B. Topo Map
C. Soils Map
D. Flood Plain Map
E. ASCS Map

CHECKED BY. M. -1 s E.
DATE: —ki ig, / �
T� LAGOON DESIGN CHECK LIST
1. Copy of 026 and maps if clearing involved.
2. Dam safety -
NIA a. Dike over 15 feet to down stream slope and over 10 acre feet storage to top of
dike.
3. Adequacy of storage volumes -
_✓ a. designed volume exceeds needs
b. all temporary storage stored above seasonal high watertable
✓ C. include statement from landowner when he requests no sludge storage
d. minimum 6 feet treatment volume depth
4. Operation & Maintenance Plan (sheet) -
✓ a. begin and end pump -out elevations
5. Location sketch -
_✓ a. distances to nearest residence
✓ b. road numbers
C. north arrow
6. Hazard Classification Sheet (NC-ENG-34) -
✓ a. distance to nearest stream in event of dike failure
b. distance to nearest public road in event of failure
✓ C. topo map showing lagoon location and information to support a&b
7. Waste Utilization Plan
�[ a. show all tracts & field numbers, field acreage, crops
b. signatures of producer & person preparing plan
WA C. agreement sheet signed by adjoining landowner if needed - showing tract
numbers, field numbers, acres, etc.
d. ASCS maps of fields to be used for effluent disposal
e. soil survey sheets showing all fields
f. check suitability of soils for crops planned
g. include attachment "B". on sampling procedure
8. Soil Investigation Sheet (SCS-ENG-538)
a. minimum of three borings on CIass IV & V lagoons
b. borings 2.0' below designed bottom of lagoon
✓ C. location & elevation of borings in relation to grid survey
d. seasonal high watertable
9. Seeding specifications included (lagoon dike and other exposed areas around buildings)
1

10.
Construction Specifications (sheet included)
_✓
a. need for cut-off trench addressed
b. need for sealing or lining with impervious material addressed and anticipated
locations of such area identified
✓
C. protection of liner during initial filling and near flush pipes addressed
11.
Grid Sheet (original or ledgable copy)
�L
a. gridded area large enough to include embankment slopes and surface water
diversions
b. location & ' dimensions of lagoon & buildings shown (lagoon inside top
measurements shown and lagoon corners identified by grid stations)
C. surface water removal (pipes, outlets, etc) shown
d. soil borings location show
C. TBM location & elevation shown
f. existing utilities located (if applicable)
12.
Typical cross-section included
a. dike elevation & top width shown
i
b. lagoon bottom elevation shown
_✓
C. side slopes shown
d. effluent outlet pipe invert elevation shown
✓
e. building pads - elevation & grade shown
�g
f. cut-off trench shown - if required
✓
g. liner shown - if required
13.
Volume Computations
a. excavation
i
b. dike fill
c, pad fill
14.
Summary Sheet
✓
a. design requirements — 5�4 1-adaaH QaS�.�
b. excavation volume
✓
C. fill volumes Sec voluw! ca��,
✓
d. cut -fill ratio CkisrF;ils cal.,��k�cr
e. job class
15. Location of subsurface drainage (if present)
16. Presence of utilities addressed
✓ 17. Observation of cultural resources statement included
18. Operation is outside of jurisdictional limits of municipalities
2

IMPORTANT INFORMATION
ABOUT LAGOON CONSTRUCTION
LISTED BELOW IS A BRIEF SUMMARY OF VOLUMES AND OTHER
DATA: (SEE CONTENTS OF PLAN FOR MORE INFORMATION)
EXCAVATION 4610--- cubic yards
FILL (pad & dike) 4610---- cubic yards
TOP SOIL (minimum 3" thick) 197--- cubic yards
CLAY LINER (represents a complete liner) 1770--- cubic yards
Constructed top of dam must include a minimum of 5% settlement -
EXAMPLE: 10 feet high dam will require 5% of 10 feet or 0.5 feet
fill above planned top of dam.
Clay content, thickness and compaction of liners (if required) are
very important. If the certifying technical specialist is unable
to approve the liner with normal field techniques, an independent
engineering analysis will be required (see CONSTRUCTION
SPECIFICATIONS for additional information). If an independent
engineering analysis is required, this expense will be the
responsibility of the owner/grower.
Special attention needs to be given to the seeding specifications.
The lagoon dike must be seeded according to specifications before
the system can be certified and stocked with animals. (Consult
with your NRCS Conservationist regarding mulching)

I
I
MEMORANDUM
TO: All Prospective Contract Growers
FROM: Don Butler, Real Estate Manager
Howard Hobson, Resource Conservationist
RE: Legal requirements for swine growers in
North Carolina and how they relate to you
The facility design -and waste management plan attached is of the utmost importance to
you and to Carroll's. This plan must be approved by a designated technical specialist
or Professional Engineer prior to construction start. The lagoon must be constructed
exactly as designed unless changes are approved by the original designer. The approved
plan needs to become a part of your permanent records and must be readily available
for review if and when your farm is inspected by state regulatory personnel.
When earthwork and lagoon construction is complete and the top of the dike and
outside slopes of the lagoon have been graded, seeded, and fertilized it must pass a final
inspection by a designated technical specialist in order for your farm to be certified
ready to stock animals. At the time of final construction approval, the owner and the
person certifying construction must sign a document called "Certification for New or
Expanded Animal Feedlots" (a blank of this form is enclosed in your package) and this
form must be sent to the Department of Environmental Health and Natural Resources
In Raleigh. Copies of the signed document should be kept in your permanent file, one
copy goes to your local Soil and Water Conservation District office for their file, and a
copy must be presented to Carroll's Foods before any animals can be placed on your
farm. The owner is responsible for the Certification being completed and sent to the
appropriate places. Remember, NO CERTIFICATION -- NO ANIMALS.
If you have any questions about the above information, please contact one of
us by calling 910-293-3434, extension 246.

ATTENTION OWNER _ AND EARTH MOVING CONTRACTOR
PLEASE READ THIS BEFORE REVIEWING THE ATTACHED WASTE
MANAGEMENT PLAN.
This design has been prepared in accordance with USDA- Natural Resources Conservation
Service standards and properly installed, will allow certification and stocking of animals.
The following items should be discussed PRIOR to entering into a contract:
1. This design is in compliance with state and federal laws. Any changes in design may
result in non-compliance and failure to be eligible for certification. No animals can
be stocked until the lagoon construction is approved and certified to the Division of
Environmental Management (DEM). If a Dam Safety Permit is also required by the
State,"tlren no water or animal waste may be impounded in the lagoon until the
lagoon and. dike construction are approved by the North Carolina Department of
Environment, Health and Natural Resources, Division of Land Resources (DLR).
2. This design has taken into account data including soils, topography, wetlands,
streams, dwellings, wind direction, and owners concerns.
3. The volume shown represents excavation and fill in the lagoon and pad area. It does
NOT account for cut/fill for liners, roads, borrow areas, drainage or other related
construction activities unless specifically covered in the design.
4. Typically, the excavation volume represents the bulk of earthwork and is used for
price negotiations. All earth work beyond this amount will be worked out between
the owner and contractor, CARROLL'S DOES NOT NEGOTIATE PRICES FOR
GROWERS.
5. It is the desire of Carroll's Foods that the contractor receives a fair price for earth
work and the land owner receives a properly constructed lagoon and pad that will
meet design requirements.
d. DO NOT MAKE ANY CHANGES TO THE DESIGN OR FARM LAYOUT
UNLESS THE ORIGINAL DESIGNER IS CONSULTED AND APPROVES.
CARROLL'S FOODS ASSUMES NO RESPONSIBILITY FOR ANY DEVIATION
FROM ORIGINAL DESIGN OR CHANGES MADE ON THE SITE BY
CONTRACTOR OR ANYONE OTHER THAN CARROLL'S PERSONNEL.

a
United States
Department M
Agriculture
r' t
Natural NC-CPA-17
Resources REV. 1, 2-96
Conservation
Service
WASTE MANAGEMENT FACILITY SITE EVALUATION
GENERAL 1NFORINIATION
NAME MA Tim _ G61CCAS12
EggLA-frLLLE NC^Z85fa
TELEPHONE 91 O - Z98 - GZS 1
LOCATION )2aytzm __ _
SIZE OPERATION 33754 Wen, im—Frtclev'
LOCATION DATA
DISTANCE FROM NEAREST RESIDENCE NOT OWNED BY PRODUCER 1. 174o FT.
DISTANCE FROM NEAREST PUBLIC FACILITY (school, church, etc,) ? Z,SGr 0 FT.
1S SFM WITHIN 100-YEAR FLOOD PLAIN?
YES _ NO _✓
Ifyes, MRCS cannot provide assistance.
IS SrM AT LEAST 100 FT. FROM A "BLUE LINE" PERENNIAL STREAM?
YES _✓ NO
If no, site must be relocated.
IS SrrE WnTII I MILE ZONING JURISDICTION OF A MUMCIPALITY?
YES _ NO
If yes, landowner should consult with local zoning board about required
permits. Permits must be obtained prior to design approval.
ARE UTILITIES IN CONSTRUCTION AREA?
YES NO
If yes, see fart 503 of the National Engineering Manual and follow policy.
(Copies of maps or other reference materials may be attached to site
evaluation.
WETLANDS
WILL SITE INVOLVE CLEARING WOODLAND OR ANY NON -CROPLAND? YES NO
If yes, producer must complete Form NRCS-CPA-38 (Request for Certified
Wetland Determination/DeIineation).
WILL ACTION RESULT IN SWAMPBUSTING? YES NO
IF WETLANDS ARE INVOLVED, IT IS THE RESPONSIBILITY OF THE PRODUCER TO CONTACT THE US ARW CORP OF
ENGINEERS AND THE DIVISION OF ENVIRONMENTAL MANAGEMENT TO DETERMINE IF PERMITS ARE REQUIRED.
IF WETI ANDS ARE INVOLVED, THE PRODUCER SHOULD NOT CLEAR ANY LA,W UNTIL A WETLAND DELINEATION
IS MADE.
MRCS will provide technical assistance in wetlands only under the following conditions. For natural wetland
inclusions less than one acre in size, MRCS will provide assistance only if the functions and values lost are fully
mitigated. For natural wetlands greater than one acre in size, MRCS will provide assistance only after a
rigorous sequencing process to include avoidance, minimization of impacts, and compensatory mitigation is
carried out in that order of preference.
ODOR CONTROL
HAS ODOR CONTROL BEEN DISCUSSED WITH PRODUCER:
• PREDOMINANT WIND DIRECTION? YES ✓ NO
• PRECHARGING LAGOON WITH FRESH WATER TO AT LEAST 1/2 YES ✓ NO
OF THE CAPACITY?
• USING GOOD SOUND JUDGMENT IN LAND APPLICATION YES _✓ NO
OF WASTE?

NC-CPA-17
REV. 1, 2-96
Page 2
OTHER ENVIRONMENTAL. FACTORS
IS ENDANGERED AND/OR THREATENED SPECIES HABITAT PRESENT? YES NO
IS A DESIGNATED NATURAL SCENIC AREA INCLUDED IN THE PLANNING AREA OR
WILL PLANNED ACTIONS IMPACT ON AN ADJACENT NATURAL SCENIC AREA? YES NO
15 AN ARCHAEOLOGICAL OR HISTORICAL SITE LOCATED IN THE PLANNED AREA? YES NO
ARE THERE PRIME, UNIQUE, STATE OR LOCALLY IMPORTANT FARMLANDS IN THE YES ✓ NO
OPERATING UNIT?
WILL THE ACTION RESULT IN SODBUSTING? YES _ NO
If the answer to any of the above is yes, NRCS will not provide technical
assistance unless agency oli is followed.
WASTE MANAGEMENT
DOES PRODUCER OWN ENOUGH LAND TO PROPERLY LAND APPLY ALL WASTE YES NO
INCLUDING SLUDGE, ALTHOUGH SLUDGE MAY ONLY BE APPLIED INFREQUENTLY?
IF NO, DOES PRODUCER HAVE ACCESS TO MORE LAND? YES _ NO
IF LAND IS NOT OWNED BY PRODUCER, CAN PRODUCER GET AGREEMENT ON LAND YES � NO
ON WHICH TO APPLY WASTE?
(Attach Waste Utilization Plan to site evaluation.)
SOIL INVESTIGATION . VALID ONLY IF SOIL INVESTIGATION
SHEET ATTACHED
IS SOIL SUITABLE FOR LAGOON?
YES
NO
IS A LINER REQUIRED?
YES ✓
NO
TYPE OF LINER TO BE USED:
CLAY ABENTONITE SYNTHETIC
IF CLAY LINER IS TO BE USED, IS SUITABLE CLAY AVAILABLE ON
YES ✓
NO
SITE?
IF CLAY IS NOT AVAILABLE ON SITE, DOES LANDOWNER HAVE
YES
NO
ACCESS TO CLAY?
IS ACORE TRENCH REQUIRED?
YES _
NO ✓ (v,st �:hrr�
(Attach soil investigation sheet to site evaluation.)
IS SUBSURFACE DRAIN TILE PRESENT?
YES
NO
(If yes, tile must be removed or plugged)
SITE APPROVED YES NO CONDITIONAL
COMMENTS L IMC-<2 [;.fzs�tu=rt[V t'-YWC-7PT _ W AEQE_ 5 C o R
^ CL_ mVpF 52A4 AGte- Faun10.
THIS SITE INVESTIGATION IS VALID FOR TWELVE MONTHS FROM THE DATE SHOWN BELOW. IF CONSTRUCTION
HAS NOT BEEN STARTED WITHIN TWELVE MONTHS, A NEW SITE INVESTIGATION WILL BE REQUIRED. "
SIGNATURE
DATE (S i
1� Changes in the local or state law or changes in the standard could require a new site investigation.

SCS-ENG-538 U. S. DEPARTMENT OF AGRICULTURE
Rev. 5-70 SOIL CONSERVATION SERV{CE
SOIL INVESTIGATIuN TO DETERMINE SUITABILITY OF PRLr'OSED POND SITE
W1. M rRR w
• • • r-
■
■
■■■s■■■■©■©■■■■■■■■■■■
■
■
■■■
■■■®■■■®ii
MMOOMMOE
■EMIMMIN
MEMO-
{
■■■■■■■■■■■■
■■■■■■�l■■E■■
G
■__i■■■■■■■
■■�■■■■■��■e■s
■■�r■■■■■■■r■
■
■
MMW
■■■
■■■■■EEE■■■■
■
e■■K■■■■
ri■
eEee■■■■ee■e■■
■■■■■■■■■■■s■■■■■■■Mee■■■
BORING
NaAr and list dam -site and ivillway &drws
NUMBER AND.•
flr-st - Men panded area and borrow pit borfngs - separate wilh Lpergwj r#d ftn4L
ter table clevagovis on dam -site borfrigs.
im�mimi®gym!®�m�®gym
moo
m1310
�!�'�If■I�'!'■i■�■I
�I■I■1■i■I■1■;■ICI■�fE�■I■IE
E��'■Itl■■iE'■i■
©iei■f
■f■I■
■i■
■i■'■I■i■i■
■
�7!t���
�!.":!�:®■
�■;�
■i�iii'■
■AEI■
■�■'■!■'■i■
:. ?A-$&,
W/ 14"W RO HoF,Scrj, cmaus

TYPES OF M J­ RIAL ENCOUNTERED IN BORINGS
{lj one of systems below) S
UNIFIED CLASSIFICATION
GW - Well graded gravels; gravel, sand mix
GP -Poorly graded gravels
GM - Silly gravels; gravel -sand -silt mix
GC - Clayey gravels; gravel -sand -clay mix
SW -Well graded sands; sand -gravel mix
SP-Poorly graded sands
SM-Silty sand
SC -Clayey sands; sand -clay mixtures
ML - Silts; silty, v, fine sands; sandy or clayey silt
CL - Clays of low to medium plasticity
CH -Inorganic clays of high plasticity
MH - Elastic silts
OL-Organic silts and silty clays, low plasticity
OH - Organic clays, medium to high plasticity
1. Suitable material for embankment is available
r axrse side)
REMARKS:
USDA CLASSIFICATION
g- gravel
s - sand
vfs - very fine sand
sl -sandy loam
fsl - fine sandy ,loam
1- loam
gl -gravelly loam
si - silt
sil-silt loam
cl-clay loam
sicl-silty clay loam
scl-sandy clay loam
sic - silty clay
c -clay
'es = No (indicate where loculea on the sketch art
Foclet*5 .I so.d l-ervs •-sixth wSQ. vm
;4�n alt-rt.-x.
Extra e � a•r sha• 1 ,r,a�r �o Q;tJ11rr YeICLVe ah� 1;'e
ryas ar Y4*'+av@ a..^a1 r`1+X l3 ✓'WAlytb,
2 Explain hazards requiring special attention in design (Seepage, spring, -roc* etcl
GENERAL REMARKS:
11

i
LAGOON DESIGN
)perator:MARTY BLIZZARD County: DUPLIN Date: 06/06/96
Distance to nearest residence (other than owner): 1500.0 feet
L. AVERAGE LIVE WEIGHT (ALW)
0
sows
(farrow to
finish)
x
1417
lbs.
- 0
lbs
0
sows
(farrow to
feeder)
x
522
lbs.
= 0
lbs
0
head
(finishing
only)
x
135
lbs.
- 0
lbs
0
sows
(farrow to
wean)
x
433
lbs.
- 0
lbs
3552
head
(wean to feeder)
x
30
lbs.
- 106560
lbs
Describe other :
0
Total Average Live Weight = 106560 lbs
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 106560 lbs. ALW x Treatment Volume(CF)/lb. ALW
Treatment Volume(CF)/lb. ALW = 1 CF/lb. ALW
Volume = 106560 cubic feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION Ket" 3?yGc.uOEb Pag- Ovl�t�ts REQsY
Volume = 0.0 cubic feet
4. TOTAL DESIGNED VOLUME
Inside top length (feet) ----------------------
Inside top width (feet) ----------------------
Top of dike elevation (feet) -----------------
Bottom of lagoon elevation (feet) ------------
Freeboard (feet) -----------------------------
Side slopes (inside lagoon) ------------------
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH
3.0 3.0 3.0 3.0 300.0
AREA OF TOP
LENGTH * WIDTH
300.0 94.0
AREA OF BOTTOM
LENGTH * WIDTH =
240.0 34.0
306.0 A$JvxA6E
100.0
48.4
37.4
1.0
3.0 : 1
28200 (AREA OF TOP)
WIDTH DEPTH
94.0 10.0
8160 (AREA OF BOTTOM)
AREA OF MIDSECTION
LENGTH * WIDTH * 4
270.0 64..0 69120 (AREA OF MIDSECTION * 4)
CU. FT. = AAREA TOP + (4*AREA MIDSECTION) + AREA BOTTOMU * DEPTH/6
28200.0 69120.0 8160.0 1.7
Total Designed Volume Available = 175800 CU. FT.

;. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
306.0 100.0 30600.0 square feet
Buildings (roof and lot water)
0.0 square feet Describe this area.
TOTAL DA 30600.0 square feet
Design temporary storage period to be 180 days.
iA. Volume of waste produced
.Feces & urine production in gal./day per 135 lb. ALW 1.37
Volume = 106560 lbs. ALW/135 lbs. ALW * 1.37 gal/day 180 days
Volume = 194650 gals. or 26022.7 cubic feet
>B. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume = 71.0 gallons/day * 180 days storage/7.48 gallons
per CF
Volume = 1708.6 cubic feet
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180-days excess rainfall = 7.0 inches
Volume = 7.0 in * DA / 12 inches per foot
Volume = 17850.0 cubic feet

I ,
�tD. Volume of 25 year - 24 hour storm
Volume = 7.5 inches / 12 inches per foot * DA
Volume = 19125.0 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 26023 cubic feet
5B. 1709 cubic feet
5C. 17850 cubic feet
5D. 19125 cubic feet
TOTAL 64706 cubic feet
6. SUMMARY
Temporary storage period====================>
180
days
Rainfall in excess of evaporation===========>
7.0
inches
25 year - 24, hour. rainfall==================>
7.5
inches
Freeboard=====================-======--=====>
1.0
feet
Side slopes==============-==================>
3.0
1
Inside top length===========================>
306.0
feet
Inside top width============================>
100.0
feet
Top of dike elevation==== ==================>
48.4
feet
Bottom of lagoon elevation==================>
37.4
feet
Total required volume=======================>
171266
cu. ft.
Actual design volume========================>
175800
cu. ft.
Seasonal high watertable elevation (SHWT)===>
44.0
feet
Stop pumping elev.-=------===--W==_______-__>
44.6
feet
Must be > or = to the SHWT elev.======--==>
44.0
feet
Must be > or = to min. req. treatment el.=>
43.4
feet
Required minimum treatment volume===========>
106560
cu. ft.
Volume at stop pumping elevation============>
106939
cu. ft.
Start pumping elev.__--------
46.6
feet
Must be at bottom of freeboard & 25 yr. rainfall
Actual volume less 25 yr.- 24 hr. rainfall==>.
156675
cu. ft.
Volume at start pumping elevation===========>
155310
cu. ft.
Required volume to be pumped================>
45581
cu. ft.
Actual volume planned to be pumped==========>
48371
cu. ft.
Min. thickness of soil liner when required==>
1.6
feet
7. DESIGNED BY : Q'�• APPROVED BY:
[AsZA4l1.3 -aoD5, rift -
DATE: DATE: 6110?c
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
COMMENTS:

N
WAR" $LIZZARM 1- NER (%KPLs'K'r0AS
D. Volume of 25 year - 24 hour storm
Volume = 7.5 inches / 1.2 inches per foot * DA
Volume = 21618.6 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A.
26023
cubic
feet
5B.
1709
cubic
feet
5C.
20177
cubic
feet
5D.
21619
cubic
feet
TOTAL 69527 cubic feet
b. SUMMARY
Temporary storage period====================>
180
days
Rainfall in excess of evaporation===========>
7.0
inches
25 year - 24 hour rainfall==================>
7.5
inches
Freeboard==== ==============================>
1.0
feet
Side slopes_________________________________>
3.0
��OTS0
: 1 00
Inside top length===========================>
315.6
feet DRA£�es' lJl�'
F
Inside top width====________________________>
109.6
feet 1-6F,
Top of dike elevation=======================>
48.4
fee
Bottom of lagoon elevation==================>
35.8
feet
Total required volume=======================>
176087
cu. ft.
Actual design volume========================>
223585
cu. ft.
Seasonal high watertable elevation (SHWT)===>
44.0
feet
Stop pumping elev.===_______________________>
44.6
feet
Must be > or = to the SHWT elev.==========>
44.0
feet
Must be > or = to min. req. treatment el.=>
41.8
feet
Required minimum treatment volume===========>
106560
cu. ft.
Volume at stop pumping elevation========_===>
144505
cu. ft.
Start pumping elev._________________________>
46.6
feet
Must be at bottom of freeboard & 25 yr. rainfall
Actual volume less 25 yr.- 24 hr. rainfall==>
201966
cu. ft.
Volume at start pumping elevation===========>
200221
cu. ft.
Required volume to be pumped================>
47909
cu. ft.
Actual volume planned to be pumped==========>
55716
cu. ft.
Min. thickness of soil liner when required==>
..1-.8--€apt
AA
4 ,+,,
7. DESIGNED BYAU'0tJOL APPROVED BY:
C��at�:5 �cq3
DATE: DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
COMMENTS: JoLoMI- kSTIMAMS Ede- 1-tRE2
AND
3 „ OF ,aasoIL.
-br5j6&j 1NU 58 5 $52 `C .�s�(a s� 2 7 = 1976A•4,-6
n '[la L1WL 17 5, Sao C`
4.7, `185 Ce,�•�l 1770 Cu
1� cwkl�•�td

HAZARD CLASSIFICATION DATA SHEET FOR DAMS
Landowner Marty Blizzard County Duplin
Estimated Depth of Water to Top of Dam +3 Ft. Length of Flood Pool +300 Ft.
Date of Field Hazard Investigation 5/23/96
Evaluation by reach of flood plain downstream to the point of estimated minor effect from sudden
dam failure.
Est. Elev.
Est. Elev.
Kind of ;Improvements'
of Breach
Reach
Length Width
Slope Land Use Improvements Above
Floodwater Above
Flood Plain 1
FIood Plain
Ft. Ft.
% Wooded None t$'
NIA
1
300 75
> 1 %
2
3
'
Describe potential for loss of life and damage to existing or probable future downstream improvements
for a sudden breach. A sudden failure of the structure will not endanger life nor cause sienificant
damage to buildings _agricultural land, or public roadways._ The structure is_approximately2,300 feet
from a tributary leading to Limestone Creek and approximately 2,000 feet from SR 1702.
Hazard Classification of Dam (A, B, C) (see NEM-Part 520.21) A
NRCS Dam Classification (I, II, III, IV, V) II
By Date June 19, 1996
M. Floyd Adams, P.E.

r SHEET 1 OF 2
OPERATION AND MAINTENANCE PLAN
This lagoon is designed for waste treatment (permanent storage) and
180 days of temporary storage. The time required for the planned
fluid level (permanent and temporary storage) to be reached may vary
due to site conditions, weather, flushing operations, and the amount
of fresh water added to the system.
The designed temporary storage consists of 180 days storage for:
(1) waste from animals and (2) excess rainfall after evaporation. Also
included is storage for the 25 year - 24 hour storm for the location.
The volume of waste generated from a given number of animals will be
fairly constant throughout the year and from year to year, but excess
rainfall will vary from year to year. The 25 year rainfall will not
be a factor to consider in an annual pumping cycle, but this storage
volume must always be available.
A maximum elevation is determined in each design to begin
pumping and this is usually the outlet invert of pipe(s) from
building(s). If the outlet pipe is not installed at the elevation to
begin pumping, a.permanent marker must be installed at this elevation
to indicate when pumping should begin. An elevation must be established
to stop pumping to maintain lagoon treatment depth.
Pumping can be started or stopped at any time between these two
elevations for. operating convenience as site conditions permit, such as
weather, soils, crop, and equipment in order to apply waste without
runoff or leaching.
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent damage to crops.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be. pre -
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times. When precharging is complete,
flush buildings with recycled lagoon liquid. Fresh water should not
be used for flushing after initial filling.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see attachment)
before land application.
3. Begin temporary storage pump -out of the lagoon when fluid level
reaches the elevation 46.6 as marked by permanent marker. Stop pump -
out when the fluid level reaches elevation 44.6 . This temporary
storage, less 25.yr- 24 hr storm, contains 45581 cubic feet or
340948 gallons.

• P SHEET 2 OF 2
i
4. The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended maximum application rate is 0.3
inch per hour. Refer to the waste utilization plan for further details.
5. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
outlets.
8. Keep a minimum of 25 feet of grass vegetated buffer around
waste utilization fields adjacent to perennial streams. Waste will
not be applied in open ditches. Do not pump within 200 feet of a
residence or within 100 feet of a well. Waste shall be applied in a
manner not to reach other property and public right-of-ways.
9. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of -the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.

SHEET 1 OF 2
SPECIFICATIONS FOR CONSTRUCTION OF WASTE TREATMENT LAGOONS
----------------------------------------------------------
FOUNDATION PREPARATION:
-----------------------
The foundation area of the lagoon embankment and building pad shall be
cleared of trees, logs, stumps, roots, brush, boulders,sod and rubbish.
Satisfactory disposition will be made of all debris. The topsoil from
the lagoon and pad area should be stripped and stockpiled for use on
the dike and pad areas. After stripping, the foundation area of the
lagoon embankment and building pad shall be thoroughly loosened prior
to placing the first lift of fill material to get a good bond.
EXCAVATION AND EARTHFILL PLACEMENT:
------------------------------------
The completed excavation and earthfill shall conform to the lines,
grades, and elevations shown on the plans. Earthfill material shall
be free of material such as sod, roots, frozen soil, stones over
6 inches in diameter, and other objectionable material. To the extent
they are suitable, excavated materials can be used as fill. The fill
shall be brought up in approximately horizontal layers not to exceed 9
inches in thickness when.,loose and prior to compaction. Each layer
will be compacted by complete coverage with the hauling and spreading
equipment or standard tamping roller or other equivalent method.
Compaction will be considered adequate when fill material is observed
to consolidate to the point that settlement is not readily detectible.
NOTE THE SPECIAL REQUIREMENTS FOR PLACEMENT OF LINERS IN THE LINER
SECTION OF THIS SPECIFICATION. The embankment of the lagoon shall be
installed using the more impervious materials from the required
excavations. Construction of fill heights shall include 5 percent for
settlement. Dikes over 15 feet in height and with an impoundment
capacity of 10 acre-feet or more fall under the jurisdiction of the NC
Dam Safety Law. The height is defined as the difference in elevation
from the constructed height to the downstream toe of the dike.
Precautions shall be taken during construction to prevent excessive
-erosion and sedimentation.
LINER: THE MINIMUM REQUIRED THICKNESS SHALL BE 1.6 ft.
NOTE: LINERS (PARTIAL OR FULL) ARE REQUIRED WHEN THE ATTACHED SOILS
INVESTIGATION REPORT SO INDICATES OR WHEN UNSUITABLE MATERIAL IS
ENCOUNTERED DURING CONSTRUCTION. A TYPICAL CROSS SECTION OF THE LINER
IS INCLUDED IN THE DESIGN WHEN LINERS ARE REQUIRED BY THE SOILS REPORT.
When areas of unsuitable material are encountered, they will be over -
excavated below finish grade to the specified depth as measured
perpendicular to the finish grade. The foundation shall be backfilled
as specified to grade with a SCS approved material (ie - CL,SC,CH).
REFER TO THE SOILS INVESTIGATION INFORMATION IN THE PLANS FOR SPECIAL
CONSIDERATIONS.

SHEET 2 OF 2
Soil liner material shall come from an approved borrow area. The
minimum water content of the liner material shall be optimum moisture
content which relates to that moisture content when the soil is kneaded
in the hand it will form a.ball which does not readily separate. Water
shall be added to borrow as necessary to insure proper moisture content
during placement of the liner. The moisture content of the liner
material shall not be less than optimum water content during placement.
The. maximum water content -relates to the soil material being too wet
for efficient use of hauling equipment and proper compaction. Proper
compaction of the liner includes placement in 9 inch lifts and
compacted to at least 90 percent of the maximum ASTM D698 Dry Unit
Weight of the liner material. When smooth or hard, the previous lift
shall be scarified and moistened as needed before placement of the next
lift.
The single most important factor affecting the overall compacted perme-
ability of a clay liner, other than the type of clay used for the
liner, is the efficient construction processing of the compacted liner.
The sequence of equipment use and the routing of equipment in an estab-
lished pattern helps assure uniformity in the whole placement and
compaction process. For most clay soils, a tamping or sheepsfoot
roller is the preferable type of compaction equipment.
The soil liner shall be protected from the discharge of waste outlet
pipes. This can be done by using some type of energy dissipator(rocks)
or using flexible outlets on waste pipes.
Alternatives to soil liners are synthetic liners and bentonite sealant.
When these are specified, additional construction specifications are
included with this Construction Specification.
CUTOFF TRENCH:
--------------
A cutoff trench shall be constructed
shown on a typical cross section in
cutoff trench shall be determined by
materials.
/VEGETATION:
under the embankment area when
the plans. The final depth of the
observation of the foundation
All exposed embankment and other bare constructed areas shall be seeded
to the planned type of vegetation as soon as possible after construc-
tion according to the seeding specifications. Topsoil should be placed
on areas of the dike and pad to be seeded. Temporary seeding or mulch.
shall be used if the recommended permanent vegetation is out of season
dates for seeding. Permanent vegetation should be established as soon
as possible during the next period of approved seeding dates.
REMOVAL OF EXISTING TIbE'DRAINS
-------------------------------
When tile drains are encountered, the tile will be removed to a minimum
of 10 feet beyond the outside toe of slope of the dike. The tile
trench shall be backfilled and compacted with good material such as
SC, CL, or CH.

SEEDING SPECIFICATIONS
i----------------------
AREA TO BE SEEDED: 2.0 ACRES
USE THE SEED MIXTURE INDICATED AS FOLLOWS:
0.0 LBS. FESCUE GRASS AT 60 LBS./ACRE
(BEST SUITED ON CLAYEY OR WET SOIL CONDITIONS)
SEEDING DATES: SEPTEMBER 1 TO NOVEMBER 30
FEBRUARY 1 TO MARCH 30
0.0 LBS. RYE GRAIN AT 30 LBS./ACRE (NURSERY FOR FESCUE)
0.0 LBS. 'PENSACOLA' BAHIA GRASS AT 60 LBS./ACRE
(SEE FOOTNOTE NO. 1)
SEEDING DATES: MARCH 15 TO JUNE 15
16.0 LBS. HULLED COMMON BERMUDA GRASS AT 8 LBS./ACRE
(SUITED FOR MOST SOIL CONDITIONS)
SEEDING DATES: APRIL 1 TO JULY 31
0.0 LBS. UNHULLED COMMON BERMUDA GRASS AT 10 LBS./ACRE
SEEDING DATES: JANUARY 1-TO MARCH 30
0.0 LBS. RYE GRASS AT 40 LBS./ACRE (TEMPORARY VEGETATION)
SEEDING DATES: DECEMBER 1 TO MARCH 30
LBS.
APPLY THE FOLLOWING:
2000.0 LBS. OF 10-10--10 FERTILIZER (1000 LBS./ACRE)
4.0 TONS OF DOLOMITIC LIME (2 TONS/ACRE)
200.0 BALES OF SMALL GRAIN STRAW (100 BALES/ACRE)
ALL SURFACE DRAINS SHOULD BE INSTALLED PRIOR TO SEEDING. SHAPE
ALL DISTURBED AREA IMMEDIATELY AFTER EARTH MOVING IS COMPLETED.
APPLY LIME AND FERTILIZER THEN DISK TO PREPARE A 3 TO 4 INCH
SMOOTH SEEDBED. APPLY SEED AND FIRM SEEDBED WITH A CULTIPACKER
OR SIMILAR EQUIPMENT. APPLY MULCH AND SECURE WITH A MULCH
ANCHORING TOOL OR NETTING.
1. PENSACOLA BAHIAGRASS IS SLOWER TO ESTABLISH THAN COMMON
BERMUDA GRASS. WHEN'USING BAHIA, IT IS RECOMMENDED THAT 8
LBS./ACRE OF COMMON BERMUDA BE INCLUDED TO PROVIDE COVER
UNTIL BAHIAGRASS IS ESTABLISHED.
n

V IAMMULL a r-UuuZD,, INU.
_.._ ....--' _._............._.� __�_ ..._........ ..AR:,,..1 N•., 339•,-
:. Project: WASM MANaaehotr ,A
Drawing: s t-M L,x+4 0 �P
Location: pupLtg eou!�
. _._Engineer:
_,.......:.:.:... ....Scale.,o.
Prepared B a' 77
T '
----•--4 QO -'
... -:-+.
—----- -----
NAIL IN 6" GUM
-----------------
T6 PI
-r
— atQQ:3 43. _ — 100
3
45T — -_
... _
7
S$2 . • �i .
30
�9.
SBl
._ ....__.....---.•..:..:.... ........' _ --_. _ .. _ .. .....- .--..- Z'E., ,. ON�Rf1Ci0i� . �i .C41c�K. �.R: .5ug5uf;t'AeE. �RAztJ:_L-Ih�� ..
i I
• ! t ! -
f
T CDN�1'RA T:_ RO.WER=SMARTY==bL1ZZ/�RD:..�_._. i--..... _.._�.
:48.3---
485------- r
i........_.
,......_:...
_,.
-
_
:
146LG
o'
49�o
u

Swine Confinement
Building
Finished Floor Elev.
TOP Pad Elev. 4-8.3
ump
8" Pipe
Invert Elev. 4.. s
TYPICAL CROSS-SECTION
Single Stage Lagoon -Pit Recharge Design
.nOacIN County, NC
4-7.
MARTI &tZEAR'O
Total Design Storage Elev. ¢-7.:S5
Invert Outlet Pipe Elev. 44.r o
Stop Pump Elev. 44.,
Bottom Elev.-37.4..
jZX = O.Z0
Support post
.............
Natural'..Ground;:: _
141 FT. DESIGN MIN. CLAY LINER THICKNESS. "`" 'i- �k };;• w
areas of unsuitable material encountered during �nstruction
of lagoon slopes and bottom will be excavated below grade (for
the minimum clay liner thickness), backtilled (with approved soil . .
material) & compacted (to clay liner construction•specifcatia)ts
in design)..... see soils Investigation
9.9s_ft.
Settled Top Dam Elev.
Add 5% Settlement
Constructed Top Dam
cr?
4S.
Core
Trench'
Remove overburden material and
establish embankment/core on firm
soil material .... see soils Investigation
R. Horton. MRCS (2195)

Orientation: -46.0
48.
48.
47.
47.
46.
46.
46.
Lower Left
Z Magnification: 43.5
30 Mesh Surface
Existing
Project: MARTY BLIZZARD
Drawing:. 3552 HEAD NURSERY
Number:
Location:
Bid Date:
Engineer:
Owner:
Estimator:
Prepared bU: using Sitework
Inclination: 28.0.
.ju musn purr ace

ig�ter
Plot of all data for the surface:
Existing
Project: MARTY BLIZZARD
Drawing: 3552 HEAD NURSERY
Number:
Location:
Bid Date:
Engineer:
Owner:
Estimator:
Prepared bU: using Sitework

erimeter
Contour plot of
Existing
Project: MARTY BLIZZARD
Drawing: 3552 HEAD NURSERY
Number:
Location:
Bid Date:
Engineer:
Owner:
Estimator:
Prepared bW: using Sitswork

00 -,it -,_.-ink' Fel' - _rc--`:
C ^1
Iterating to balancing
within 10.0 cubic
yards...
delta
Cut
F111
CUT - FILL
0.00
4610.55
4610.57
-0.01
-0.00
3952.31
6855.37
--2903.06
0.00
3952.31
6855.38
-2903.08
-0.62
4575.45
4724.60
-149.15
-0.65
i0.48
14610.80
-0.32
Lower "Proposed" by 0.65 feet.
New surface called "Balanced" has been created.
Project: MARTY BLIZZARD
Drawing: 3552 HEAD NURSERY
Number:
Location:
Bid Date:
Engineer:
Owner:
Estimator:
Prepared by: using Sitework
We m. -THts VoLutAg 'boos Kor �0ICWOII
Wi odgkc Lrr fblP- t_ t N 6a a 40"-a"
�o A05 � �RAt�a� E� � • .. ,'
tsr
oL OAOLQs Taal S, MNC-
q-T14a
='1

4!
48.
48.
Q7.
48.
48.
e,3
48
$7.
48
E
I
i
tnd u;l43 S
Sri
Plot of all data for the surface:
Balanced
Project: MARTY BLIZZARD
Drawing: 3552 HEAD NURSERY
Number:
Location:
Bid Date:
Engineer:
Owner:
Estimator:
Prepared bg: using Sitework
1.35
47
1.30
xY-a�lE 47.35
37.35
37.35
4E 3
..........................................l..`' 4 3
iDa ht 526ipgter

8 148 8
p419V 47
Contour plot of
Balanced
Project: MARTY BLIZZARD
Drawing: 3SS2 HEAD NURSERY
Number:
Location:
Bid Date:
Engineer:
Owner:
Estimator:
Prepared bW: using Sitswork
7
47
V\4
6
46
rimeter

-MP D+kE
.........................................
............................................................ ....................
-r6 P DIKE
.............................................................................................•
............................................... ........................................�
a 70
Ec. 37.35
33o�
.......................................................I.....,.....----....................................................
4B. S ..
rimeter
Plot of the contour data for the surface:
Balanced
Project: MARTY BLIZZARD
Drawing: 3552 HEAD NURSERY
Number:
Location:
Bid Date:
Engineer:
Owner:
Estimator:
Prepared hy: using Sitework

Plot of the sloping lines for the surface:
Balanced
Project: MARTY BLIZZARD
Drawing: 3552 HEAD NURSERY
Number:
Location:
Bid Date:
Engineer:
Owner:
Estimator:
Prepared by: using Sitework

RG P+ID
�.... �� 40."1 tz 4f.'.Jr -...-. 4Q.41 48.4
4S - 47 48.47 4e.477
15 IS
m m
cpA � 2 0
� z z z
m �
¢g.�a 0° 48.3o 48.3a 46 3a
48.30 '47.80 48.30 48.30 48.30 47.80 4H.30
Plot of the sloping lines for the surface:
Balanced
Project: MARTY BLIZZARD
Drawing: 3552 HEAD NURSERY
Number:
Location:
Bid Date:
Engineer:
Owner:
Estimator:
Prepared bU: using Sitework
48.35
48.47
48.30

0
���gter
: MARTY BLIZZARD: 3562 HEAD NURSERY: Balanced 06 JUN 96 2:16 PM

66.00
48.00
46. ee
44.00
42. eg
40.00
38. ee
36.00
Proposed
............ ..................... ............. ........... ................ . ...... ........... .............. .. ......................................... .............. ......................... ... . .........
Existing
..................... .. ............................. ........... .............................. . . . .. ....... ................................................................. ............................................. .............. .........
........... ........ ......... ........ .................. ...... ................ ............. ................. ........................................................................................ .......... ...... ......... ....... . .............
................... .. ...........- -. i...... ......... ...................... ........... ....... .................... ......... ................ ..................................... ..........................
.................. ......................... ........ ................ - . ................................. .............. ......................... ........................ ........ . ...... .................
.................. ................... !
...... ........... ......................................... .............. * ........ ................................ ......... ..................... "****,**-"** .................
(231.75,83.84)
<312. 64>
(231.69,396.37)
: MARTY BLIZZARD: 3562 HEAD NURSERY 06 JUN 96 2:16 Fm

WASTE UTILIZATION PLAN
----------------------
Owners name--:MARTY BLIZZARD County:DUPLIN
Mail Address-:KENANSVILLE
Type of production unit ---- :WEAN -FEED
Number of animal units-----: 3552
Type of waste facility ----- :Anaerobic Lagoon
Temporary storage period---: 180 days
Method of application ------ :IRRIGATION
Amount of animal waste produced--------------------: 1500 tons/year
Amount of plant available N produced by animals-: 1705 lbs./year
Commercial N to apply on planned acreage--------: 0 lbs./year
Your animal waste utilization plan has been specifically
developed for your swine operation. The plan is based on the
soil types, crops to be grown, and method of application for
your particular operation. The waste must be land applied at a
specified rate to prevent pollution of surface and/or ground
water. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops
where the waste is to be applied. This waste utilization plan
uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle and annual soil tests
are encouraged so that all plant nutrients can be balanced for
realistic yields of the crop to be grown.
Several factors are important in implementing your waste
utilization plan in order to maximize the fertilizer value of
the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the
needs of the crop to be grown and the nutrient content of the
waste. Do not apply more nitrogen than the crop can utilize.
Soil types are important as they have different infiltration
rates and leaching potential. Waste shall not be applied to
land eroding at greater than 5 tons per acre per year. Do not
apply waste on saturated soils or on land when the surface is
frozen. Either of these conditions may result in runoff to
surface waters. Wind conditions should also be considered to
avoid drift and downwind odor problems. To maximize the value
of nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or
not more than 30 days prior to planting. Soil incorporation
of waste will conserve nutrients and reduce odor problems.

Page 2
The acres needed to apply the animal waste is based on typical
nutrient content for this type of facility. Annual acreage
requirements may be more or less based on the waste analysis
report for your waste management facility.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract Field Soil Crop Yield Lbs. N Acres Lbs. N Month to
No. No. Type Code /Acre /Unit Used Apply
5186 1 FOA K N/A 50.00 10.0 500 S-APRIL
5186 1 FOA D 120 1.25 10.0 1500 MAR-JULY
Total 20.0 2000
Available Nitrogen (includes commercial) 1705
Surplus Or Deficit -295
Crop codes: Crop -unit
A=Barley-bu. I=Oats-bu.
B=Bermudagrass (graze) -tons J=Rye--bu.
C=Bermudagrass (hay) -tons K=Small grain(graze)-acre
D=Corn(grain)-bu. L=Small grain(hay)-acre
E=Corn(silage)-tons M=Sorghum(grain)-cwt.
F=Cotton--lbs . lint W=Wheat--bu.
G=Fescue(graze)-tons Y=Fescue(pasture)-tons
H=Fescue(hay)--tons Z=Bermudagrass(pasture)-tons

Page 3
If more commercial fertilizer is used than shown in this plan,
then additional acres of land may be needed. A three to fifteen
feet wide permanent grass filter strip should be seeded along all
ditches in fields that receive animal waste.
Additional comments:
--------------------
/-/ 5 S 5/WM -
D
A C = eN �� K=? �N
AHb
4dErP5[ >nr�
b1i'Til
,JE U7%C:l�F(77i�`fir_
��i�LliT7DN
Zf= /y��7,P� Eiy7`S
�i�DPS
��
Prepared by:W,9'71• l�soy Title: - Date: 4916,E
'Okax& ;qWa Ix' .
concurred in by: r11,71 Date4ZY
r cer
I understand that I must own or have access to equipment,
primarily irrigation equipment, to land apply the animal waste
described in this waste utilization plan. This equipment must be
available at the appropriate pumping time such that no discharge
occurs from the lagoon in a 25-year 1--day storm event. I also
certify that the waste will be applied on the land according to
this plan at, the appropriate times and .at rates that no runoff
occurs.
Date ��
P ucer
Technical Specialist: %ZO20 — dC. _ Date:
(copy to producer and copy to case file)

a
CAN. ................
b
Sol
O
12.3 AC
Fp A Sol 1--
Z.00
W
Dauligh-t--perimeter
Plot of the contour data for the surface:
Proposed
Project: MARTY BLIZZARD
Drawing: SPRAY ACRES
Number:
Location:
Bid Date:
Engineer:
Owner:
Estimator:
Prepared by: using Sitework

I
WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
EXHIBIT A-6
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any discharge of waste which reaches surface water is
prohibited.
There must be documentation in the design folder that the producer either owns or has a notarized agreement for use of
adequate land on which to properly apply the waste. If the producer does not own adequate land to properly dispose of
waste, he/she shall provide a copy of a notarized agreement with a landowner who is within a reasonable proximity,
allowing hirr/her the use of the land for waste application. It is the responsibility of the owner of the facility to secure
an update of the Waste Utilization Plan when there is a change in the operation, increase in the number of animals,
method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climate conditions, and level of management, unless there are regulations that
restrict the rate of application for other nutrients. Actual yields may be used in lieu of realistic yield tables at the
discretion of the planner.
4. Animal waste shall be applied on land eroding less than 5 tons per acre per year. Waste may be applied to land that is
eroding at more than 5 tons but less than I0 tons per acre per year providing grass�filter strips are installed where
runoff leaves the field. (See FOTG Standard 393-Filter Strips)
5. Odors can be reduced by injecting the waste or disking after waste application. Waste should not be applied when there
is danger of drift from the irrigation field
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from the site during application. No ponding should occur
in order to control odor and flies.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the surface is frozen_
9. Animal waste should be applied on actively growing crops in such a manner that the crop is not covered with waste to
depth that would prohibit growth. The potential for salt damage from animal waste should also be considered.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a high potential for leaching.
Waste nutrient loading rates on these soils should be held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more than 30 days prior to planting of a crop or forages breaking
dormancy..
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following: The outer perimeter of the
land area onto which waste is applied from a lagoon that is a component of a swine farm shall be at least 50 feet from
any residential property boundary and from any perennial stream or river other than an irrigation ditch or canal.
MRCS, NC
1UNE, 1996

EXHIBIT A-7
WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
Animal waste other than swine waste from facilities sited on or after October 1, 1995, shall not be applied closer than
25 feet to surface water. This distance may be reduced for waters that are not perennial provided adequate vegetative
filter strips are present (See Standard 393 - Filter Strips),
12. Animal waste shall not be applied closer than 100 feet from wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those owned by landowner.
14. Waste shall be applied in a manner not to reach other property and public right -of --ways.
15. Animals waste shall not be discharged into surface waters, drainageways or wetlands by a discharge or by over -
spraying. Animal waste may be applied to prior converted cropland provided it has been approved as a land
applications site by a "technical specialist". Animal waste applied on grassed waterways shall be at agronomic rates
and in a manner that causes no runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to protect the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc. are limited to areas where considered appropriate. Lagoon areas should be kept mowed and
accessible. Lagoon berms and structures should be inspected regularly for evidence of erosion, leakage, or discharge.
18. If animal production at the facility is terminated, the owner is responsible for obtaining and implementing a "closure
plan" which will eliminate the possibility of.an illegal discharge, pollution and erosion_
19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular basis to prevent breakdowns,
leaks, and spills. A regular maintenance checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops for direct human consumption.
However, if animal waste is used on crops for direct human consumption it should only be applied preplant with no
further applications of animal waste during the crop season.
21. Highly visible permanent markers shall be installed to mark the top and bottom elevations of the temporary storage
(pumping volume) of all waste treatment lagoons. Pumping shall be managed to maintain the liquid level between the
markers. A marker will be required to mark the maximum storage volume for waste storage ponds.
22. Soil tests shall be made every two years and a liquid waste analysis be taken at least twice each year consistent with
waste utilization plan. Poultry litter shall be tested prior to application. Soil and waste analysis records shall be kept
for five years.
23. Dead animals will be disposed of in a manner that meets NC regulations.
NRCS, NC
NNE, 1996

LP' _.-70N LIQUID SAMPLING
Q ATTACHMENT B
r
SAMPLE COLLECTION
A. Lagoon Liquid
1. Collect approximately 112 pint of recycled lagoon liquid from the inflow pipe to the
flush tanks.
2. From Lagoon
a. Place a small bottle (1/2 pint or less) on the end of a 10-15 foot long pole.
b. Extend the bottle 10-15 feet away from the bank edge.
c. Brush away any floating scum or debris so it is not collected with sample.
d. Submerge the bottle within 1 foot of the liquid surface.
e. Repeat at approximately 5 locations around the lagoon, place into a bucket,
thoroughly mix, and empty 1 pint into sample container.
3. From a multi -stage lagoon system collect sample from lagoon that is going to be
irrigated from.
11. SAMPLE PREPARATION AND TRANSFER
A. Place the sample for analysis into a flexible or expandable container that can be sealed. The
container should be rinsed clean with water and free of any residues but should not be
chlorinated or treated in any other way. Dry litter may also be placed in a sealed plastic bag
such as a freezer bag.
B. The sample should be refrigerated, iced or cooled, if possible or transferred to the lab
immediately.
C. Hand -delivery is the most reliable way of sample transfer, but it can also be mailed.
D. If mailed, sample container should first be protected with a packing material such as
newspaper, then boxed or packaged with wrapping paper and taped.
E. The NCDA Plant Analysis Lab provides this service for a nominal fee of $4 per sample which
should be forwarded along with the sample.
1. Address: NC Department of Agriculture
Plant Analysis Lab
Agronomic Division
Blue Ridge Road Center
Raleigh NC 27611
Phone: [phone]
Attn: Dr. Ray Campbell
F. Request that as a minimum the following analyses be performed:
1. Total nitrogen (TKN)
2. Ammonia nitrogen (NH3-N)
3. Total phosphorus UP)
4. Potassium (K)
5. Dry litter samples,should also include a total solids (TC) analysis.
G. Other analyses performed at no extra cost by the NCDA include trace minerals.

IJ
FCem
f 7aa
Zem
��•um
'• III{ \''Z t East Duplin
\.-Mem Gardens e
Yoh, ��•rgrr •,i �.---J � � � � -�_� �' � f i 1 �.
V.
�.,: ;,� CARROLL'S FOODS, INC.
WARSAW NC 28398
• ; � •`'� •�Project: • M M .
rawing:
DmtcroK
::rem __ M,4p
�. s—�\•� z / : , oration: C� .
Qa�k" Engineer.
Owner. zz�ae
•Halls 'Ile r Scale:
- � - ' •� Pre aced B lr� zoos'
em: ..

A
I. IN4
50
�L
glj1. rZ 7 ;x:L
if
d;
A �17
VV
4
A•MIL
1w. z -4 ria"L tt
L;
Ar
jp-
. �V_
OF -, .1
77
7
.7f;
10 T;
L
4K Ilk
4 ­76
W
4 1
CARROLL'S FOODS, INC.
Aw
WARSAW
NC 28398
-7:
�j
e d are• By: 46wzA Hctspi-q

X 3NOZ
�';i,�:.{ s ors ��$'•�:�'" .
►+YC�..±s- :•err•
..�.'.. '•''. ..
12
11
f�
X 3NOZ
•�:
!.;,
,4
? 5- n ' ! rip i , �
NA F
�'. •
JlT+
rr i_ i �� _ L a + A7. tr " F 4 .� fi $ • a yti
t �x� r3u ltir.S '' "w. s..✓x�a _ --. /• -OLD •rs 5. .1
5r
^j
%• � f < ! f 7' l ...+x .� .'t.�Nl1 '4 t+ L�'�^ 9ry f i> (3 .i > ..' ,� t. -r L i � �� w
�
it r1.-!'�':�, 'u'_'-:
_•
vr.-.{_k.-. r,- s. ., �'��'S �`f L,,..w,i=SY`: 'n'..'r r�..J� ...�`Fx����
IN

' d, •` N -� - - at al ,•, + . -r t M�,t - f '`. -, "s.._ -1' a,y`,- `rl M.;, a`rr --:/ f�r &. � * !I
�r�58351! -
.r�.4
a '' �+.,�`;""„��f �,i��,,} Gt!? }'° f j.^�i Y� r" �1l/�F_r �+�c „�a'�,', 't `''�"v''.�i r��y�!�cr ejS.'r�{•.S
�,{' C 14 L1,`1' ' r g„ �a it'`• i r,/C8 �, * �i:► AY�
�'+. � �� t 7�� ,�' � $ i• t� rt..: ����.j ' ;'.. ::. i [SAC r�,F;, �:r�l,rx 'i w '�{�Y.t �•r� ��'4,,�5/. •4�;,try '3.
MTss
'.L .a �, •�,+i. rr`,a� � .+ �rh7 .j ,.,:
"M1iCt• l 7 i ;,!„i.,'Z,4r.M1`,�.,
J7" ;•,j ♦ 'r 7- "y•r. n �• �.j4}'7 / 4s/, a Ya.r tR• XIL �L •,r . r Ito 1-
!z It
jj� 4 ^ ,"r{' ST {,i �. 1 ' 1 +ii' •A• lµ r `t. 1 +�,N •`+��: We l �•
11ut;,;3• LIT pc 81'y�;,�.,
:IMP
:Y lYrq
t . y� .� �'. i.. � .`',.•.{ - iy1�:�'4.... •• ' f' •� try � .. ;
PU
444. � iQ irt',',i .r '�.ti. �'_rs-. t. L'� a • i, r 1:1�-�=t tf�r :r a,i'.::
T.f i, :3i �!rk \ t.R �•• g� : • r •r. •`'.ram �r��t"
Rf
5 '•' �. Mre i1# f �l ^'s.4ra••t/.. t:��}((, F rr ♦,F ��'•'; -, •'
i•1`t'w+itr`-'}!'fy
"'`.h.C' .;. ,•��Jfc f •yw' :aS:�} k1N+j•;rr. Gj.. .n.� .a..
��:' 'S• r �i'.f rf'r:.. i i.: �.i.. r 5'
y "'ar:y :_Y� �� • Y a � • �,d' :+*• :i� .jh .3:. �' [._fy�a�..�{ . F,.a;+, ;f•: `. :,,L:;' - ..` r ;,tyr.�� * `'�: �t-:��'9�9ir ~!�' �Srti ((L'�4•?-1.}=;y�:�•';'%. •f,�'., i•:�:�'
' \`•�.'a. ,}. �i� t' .r a' '�• •C. 'tir l v 'fir, a,�,�: � / {'•�sz" :ti•a{.%.i:,i:ri. :��•'{ .
' � ��, ' e�7+[�+,r ►%i lY`►` ��41•..., '' � f�,�..t.:a�.� r1Jr, � . �j.�! tiy, T'r'� 1=�' �� t+I F:.:t." _ � ',r,'' ' r
�y:, \ .` ,.+,,�T-jj �� ' itY,� �S�''A.�•- � �S'hj%;,'��� r. �,: r, A ';ti'y/. �f,;`•'. :`e w.-%.,,t�.'1'':� •: �i e. �;1j:.
•� %C �� ?'�175 qi+ aT., �'pa� %re' t...: ! /7r�;•...-
/.� .�' •%00 dt. j,,l
):�T Zr:/t. , ,•'�.y'!,'r''�r�__'/ }y'�tr. 17F ,�' �.r' .y..:. .�F.�,. 'u • :ti'.1.�
1 .. '•ra' SF`fir, r,r' `�_ f•C f�.�' !i dry' 'y. �l .S-:f 1�•- .,
r� at Wit,.
,i`��*l.,�i.�I/'�: ";:�•,...; :i•`�r.•y,E,r .[�:,.1"s, ��/'�a,, •rr .. �,t�+a''•�. �'_;�
•$ti!?.,+i., '.•rr ..�
'A/ l.�y,•�i"jj'� ,iT'rrT;.••t .t»fi'1'A'. C:'Yi•�`i::: "fit '�, '''i, ..:: �• Si '.r. •r•
/ 'FI.L"'., K. r`:•'Y 1
� � . •^•��+' .R f: ?• '1'.S, f, • 7 S"•,.. '•` ti e;"� '�. M • - i• ''t y � .� � '
r' ;a'" , ;3 i ='k: 'ui ��� 'r•� �_ ' '��: `rl :� ;ls�'• .,t`::, jr y sic x ',
?". �'. Y,=+'.�.-.w11 qaT`'• :e:/iir rx ,ti:L!. 'r.l' _ r.'i
s3\ 1 :f.'J/ ` •'r:y �l.rJ 4'.s?rl!"rS�'t.��`• R v 75'eS�t'''ti•'t`�r
!
. .. -� Y�, �+r+Y .� �.�� ' `' �„ '11 •�'KSI•�/t-! • • '+l'�` +:`'y5�{yr it*y'i��.'•4'.:
' ��; +'�.�/,,�y��rar�;�i�l:, 1 /-. ` / I +�_=�'�1���i��.=�r1r`�rrC''•:�,':� d;4. :.'��,.::�:• ��:., ,� '� .pt- •••.
a / +�'l.{�aCr3':S..aL' t. �:, f.!'"i+�':.• • rr;' a ',' ,.� ...+,,, .� r . .. I4
i % �' ••♦* :�„ "T
�// r �+ a 4y?1.1�•,r.,. �. 1.', i
•` 'tM i L �+�t 'r 13 ��al. . r t 4 .' !" ', �•' • rl,y.
Link y •t'�t�+ ti}- t�4 � P �'' •ryea '74''.t:,.,,; +r ,�, a... ,�r:.x :`';'• \�.
:-� ' -:•�•r '. '"i �' �' .. .� Ir ��'.:.:• +.f�ir. .. ;J.' a +1�'•::' ' Y .,.�...' :.•'.r +• •, T
?�� t,� Jet
J zq.`, °Fi rT• ��r�`K e. .1 Y tf � - �+- : t �•'.�
�' kQii; �''�'%'h :':r:, y `
��, W r. t • � � 3 k �,,` ; . f 1y' `� �' `a=� �' . = .. '' % : 7- s i 7
w r sLr'iY � �,YW A.9� q J.. �. i! 'r;�• '+--{ " r•- • ! i'; f.ti� '�': r. _ / (� Y
3..: �.i,}�tC.�t �'',:r•:L" °fF/a l• Sys�4i. �L r /tip
yt�l,W� G , rf y• f :,'.' V• ���y�a!'f # w "Y.� t .'•'. .a:%�"•'rr Sr
�•�`',�'C'ir�?lh�i'xwilti
4r '.„ J,r:L[ '� • .!tir1,'tiys'�afi:.i 'r1 � 'N.,,•T/ 1 r yy'�'t�s. i �� �rf.•� 4 it.. r r� q•
y1 },i7 .�� i �T�f .t R •�. / ♦..%'f'i' '�'•. h•. �n•f�.T:•L'�..,'irr.: _ +x' -. R•'.. :� �•.Sr�'•••�.
,� rg ` '•" •..r.}fir' !.
h pc �'Y`�rYi ..►' ��`. ; CARROLL.'S FOODS, INC.
`.��ri r -. t:� I ►'' ;3,k ;:,{ WARSAW NC 28398
77
r:t,, !. t,Aa`.••p'rr.•� j Ar,ST'M GYBE li
;� ..<� ►f+,�f . M ,�� 1� Drawing: Mpp
ru��F+ ��� S -lyI-� :a;�(,':. �i7".�i, Wr►y'f !, r Location:
�''8 Y1:'s•.... .:.+s ! *r.;a' - 49
*�r.'�':r;: r�r Engineer: pu. Im-246L 4as 1
Owner: BLS zzD
Scale: 1 " "Of
Prepared B b�

uWQ NUN DISCHARGE BR PAGE 02
' New Erpanded EsdsdM -
General Permit Review Sheet
Eae Na: - Farm Name: i►/tio► $� i zZ��'d F 7— Date: 21�15 p -
L GeaemlInformation:
;:S= Datc : (a °I
OPbysicat Location Cmcludt map)
)IMM Lagoons 1 Houses sited: SL2,31 I
X-OWer Flame & sip==
occr %fica4m Date Certified • 14 Z 3 1b
OAddmss
0Integrato-) Name N/A
ex
13-Manager's NA= and Sipat= NIA
*tewbp
II.Operation info (fee Cases Sureadsb eet ):
AnimAl capacity and type 3552 faGgn Lp Eder g-Yearly VoIumc af,waste
Yearly PAN Q-L and Rcg1ah= cats 5 X Yields cbecked RYE esdstin,g
(Land App. Map a=apk WUP acrmge J!�ILdgadcm Parameters WA
,1!�WUP signed Date:i 2 Z 0Gb-Lease agreement NIA,-SNRCS Reg. Specs
1MVYW Review: rl1 �!►qE cc oxD]N C rtD c?� �r/j� u4rror�j
�Siti Evaluation 1 NIA Date. 1 16 Wcdmds NIA
JZ-1400n Volume Check 15-Sludp Storage NUA �OMP
Zr-Wan nD� n 2�IlA .�-FAP .6Iasec- Odor sad Mortality Chrc3clist
I7-HB 515 Requirements NIA
IV. Other,
J3-'Ptllic Response NIA-e isdng an Me one remlTiid
A2KRegioaal Response (chxk this if the RO bas no problems) "ram
,E5Comp1ian=!C-dficadan Problems (Site ibsps do ComspMnE Summary enclosrd.)
on minor problems that do not require an iadMdtW
serious problems that require an Individual permit
Comments: S;4e e•ra l v,4;on a�cd -14 h c-� scf -<;4ed .
No .sIvd e .4,gr No Lv A ,-' bo S-4c evglU 'oh
�- � z0s�c�J

Revised April 20,1999
JUSTIFICATION & DOCUMENTATION FOR MANDATORY WA DETERMINATION
agility Number=_ Operation is flagged fora wettable
=arm Name: r'1 1azo Z acre determination due to failure of
Dn-Site Representati e: Pa 11 eligibility items) F1 F2 F3 F4
inspectorlReviewer's Name:." Y"4'-4 -f Operation not required to secure WA
e---,.3 ApP• determination at this tirrAbased on
�
late of site visit:, 6rj,c15e 2-OJ exemption E1 E2 3 E4
Date of most recent WUP: Operation pended for wettable acre -
_ _ _ determination based o ' P1 p2 -P3 .
Annual farm PAN deficit pounds
J• -
Irrigation System(5) -circle -hard-Dose travels-, 2. center -pivot system; 3. linear move sysi m;
4. stationary sprinkler system w/permanent pipe; 5. stationary sprinkler system w/portable pipe;
6. stationary gun system w/permanent pipe; 7. stationary gun system w/portable pipe
PART 1. WA Determination Exemptions (Eligibility failure, Part 11, overrides Part I exemption.)
El Adequate irrigation design, including map depicting wettable acres, is complete
and signed by an I or PE.
E2 Adequate D, and Dz D3 irrigation operating parameter sheet, including map
depicting wettable acres, is complete and signed by an I or PE.
E3 Adequate 03 irrigation operating parameter sheet, including map) depicting
wettable acres, is complete and signed by a WUP.
E4 75% rule exemption as verified in Par III. (NOTE:75 % exemption cannot be
applied to farms that fail the ellgib114 checklist in Para II. Complete elioibiiity
checklist, Part II - F1 F2 F3, before completind computational.tabie in Par 1II).
PART 11. 75% Rule .Eligibility Checklist and Documentation of WA Determination
Requirements. WA Determination.requiredbecause. operation fails ane of the.eligibiiity
eouirements listedbelow:
F1 Lack.ofmcreagezvl.ichTesultedinnvermpplicatian:5zyvase�xa er(PAN) onmpimy.
field (s):accordina-fo7arm'slastiwoyearsarirricaiaun:records -.
F2 Unclear,11egibie, or lack ofinformation/map.
F3 Obviousdieldlimitabonslnumerousbitches;3aiiure:to:deductsequird
bufFerfsetback:acreaoe;mr25% oflotalacresge3dentriieddnLAWMP_•�ndudes
small,-irregularly-shaped:helds=-fields-less -than-5a cresforiravelersmrJess dhan
2 acres lorstationary-sprinklers). . .
F4 WA determination required because CAWMP credits field(s)'s a�aoe in excess
of 75% of the respective field's'total�acreade as noted In t;hj0, ;R ni -

Revised Apnl 20, 1999
Facility Number
Part Ill. Field by Field Determination of 75% Exemption Rule for WA Determination
. TRACT . FIELD TYPE oF. TOTAL. CAWMP FIELD COMMENTS3
NUMBER NUMBERI� IRRiGATiON ACRES ACRES
SYSTEM
...I I � ��I � I I •
• ! I I •I I I
t!of 11 III IK'10=I _ F,n?Ill manna nfvrnhonr Tnnv ha virnrl in nl_ra ni4a14 n—k— piener..f;., ., ..., /`AIR/I.AM
.�i...r �...... r,r �.• — ..J.........ti rr �.q �......... .r.+.... ......... �........f �— �—�..... r...�� .....r ..r.a u..r �.... r
znd type of iaigation'system. - If pulls, etc. cross more than one field, InsaectoureAe:ver will have to combine fields to
calculate 75% field by fie!d determination for exemption; mtherwise ape Gtion will be subjec", to WA determination.
PiELD NUMBER2 - must be dearly delineated on map."—'
COMMENTS' - back-up fields with CAMP acFeagLexceecmg 75% of Its to al.acres land having -received less than 50%
of its annual PAN as -documented in the farm's.7:evious1wo years' (1Ga7 & 1998) of inicatlonTe_ards. cannot serve -as -the
,sole basis for requiring a WADete.-ninafion:hack-upfie!ds-musttiemoted in the -commentz ecton znd m`e,be accassiole
by irrigation system.
Part IV. Pending WA Determinations -
P 1 Plan lacks .following inforrnation:
P2 Plan revision may:satisfy75% rile based on adequate overall PAN deficit and by
adjusting dl fieldacreage#o below 75% use rate
P3 Other (tern process of- Installing new irrigation system): v:

State of North Carolina
Department of Environment REC'Flei1 TI
and Natural Resources
Division of Water Quality . OC C�JDD
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
October 23, 2000
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Marty Blizzard
Mary Blizzard #2
141 N. Blizzard Town Road
Beulaville NC 28518
Farm Number: 31- 828
Dear Marty Blizzard:
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURcEs
You are hereby notified that Mary Blizzard #2, in accordance with G.S. 143-215.1OC, must apply for coverage under
an Animal Waste Operation General Permit. Upon receipt of this letter, your farm has sixty (60) days to submit the attached
application and all supporting documentation. In accordance with Chapter 626 of 1995 Session Laws (Regular Session
1996), Section 19(c)(2), any owner or operator who fails to submit an application by the date specified by the
Department SHALL NOT OPERATE the animal waste system after the specified date. Your application must be
returned within sixty (60) days of receipt of this letter. Failure to submit the application as required may also subject your
facility to a civil penalty and other enforcement actions for each day the facility is operated following the due date of the
application.
The attached application has been partially completed using information listed in your Animal Waste Management
Plan Certification Form. If any of the general or operation information listed is incorrect please make corrections as noted on
the application before returning the application package. The signed original application, one copy of the signed application,
two copies of a general location map, and two copies of the Certified Animal Waste Management Plan must be returned to
complete the application package. The completed package should be sent to the following address:
North Carolina Division of Water Quality
Water Quality Section
Non -Discharge Permitting Unit
1617Mail Service Center
Raleigh, NC 27699-1617
If you have any questions concerning this letter, please call Theresa Nartea at [phone] extension 375 or
Stoney Matthis with the Wilmington Regional Office at [phone].
S' erely, f/
for Kerr T. Stevens
cc: Permit File (w/o encl.)
Wilmington Regional Office (w/o encl.)
1617 Mail Service Center, Raleigh, NC 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Revised April 20, 1999
JUSTIFICATION & DOCUMENTATION FOR MANDATORY WA DETERMINATION
Facility Number ? 1 -92-8 Operation is flagged for a wettable
Farm Name: '91 r zxa-of --4-Z acre determination due to failure of
On -Site Representative: i�'I r r3 ,zLa �� Part If eligibility item(s) Fl F2 F3 F4
Inspector/Reviewer's Name:
Date of site visit: 2 `f od
Date of most recent WUP: IG �8
Annual farm PAN deficit: pounds
Operation not required to secure WA
determination at this time based on
�� Pexemption E1 E2 E3 E4
O eration ended for we le acre
P
determination based on P1 P2 P3 .
Irrigation System(s) - circicvaleermanEint
hard-hose traveler, 2. center:pivot system; 3. linear -move system;
a. stationary sprinkler s ste pipe; 5. stations sprinkler system wl ortable pipe; ry P YpP stationary P Y P PP .
6. stationary gun system wlpermanent pipe; 7. stationary gun system wlportable pipe
PART I. WA Determination Exemptions (Eligibility failure, Part 11, overrides Part I exemption.)
El Adequate irrigation design, including map depicting wettable acres; is complete
and signed by an 1 or PE.
E2 Adequate D, and D�D3 irrigation operating parameter sheets, including map
depicting wettable acres, is complete and sinned by an I or PE.
E3 Adequate D, irrigation operating parameter sheet, including map depicting
wettable acres, is complete and signed by a WUP.
E4 75% rule exemption as verified in Part 111. (NOTE:75 % exemption cannot be
applied to farms that fail the eligibility checklist in Part It. Complete eligibility
checklist, Part If - F1 FZ F3, before completing computational table in Part 111).
PART 11. 75% Rule .Eligibility Checklist and .Documentation of WA Determination
Requirements. WA Determination.required because. operation fails une of the.eliaibility
requirements listed -below: v
F1 Lack.of:acreageiwhichTesultedinmver-moplicabonmf --wastewater-, (PAN) on:spray.
fields) :according7tofarm'sdast7twoyearsmf':rmuation:records.-.
F2 Unclear, -illegible, or lack of information/map.
F3 Obvious feld,limitations-(numerous:ditches-,-:failure:to:deductTequired
buffer/setback:acreaae;-or25%:oflotal_acresgeddentinad:.in-LAWMP--includes -
small ;-irregulady-shaped fields = fields:less7than-5mcresfort# evelers:Dr.less-fhan
2 acres for. -stationary -sprinklers).
F4 WA determination required because CAWMP credits field(s)'s acreage -in excess
of 75% of the respective field's total acreage as noted in table in Part W.

Facility Number 3 -
Z
Revised April 20, 1999
Part Ill. Field by Field Determination of 75% Exemption Rule for WA Determination
TRACT
FIELD TYPE OF
TOTAL CAWMP
FIELD
NUMBER
NUMBER',2 IRRIGATION
ACRES ACRES
%
I.COMMENTS3
SYSTEM
FIELD NU m5tw - nydrant, pwt, zone, or:point numbers may oe used in place or neid numbers depending on CAWMP
and type of irrigation system. - If puffs, etc. cross -more -than one field, inspectorireviewer will have to combine fields to
calculate 75% field by field detemlinationfor exemption; -otherwise operation will be subject to WA determination.
FIELD NUMBER' -must be clearly delineated o6map.• .�
COMMENTS' - back-up fields with CAWMP acFeace:exceeding 75% of its total.acres and having received less than 50%
of its annual PAN as -documented in the farm'sprevious-two years' (1997 & 1998) of irrigationzecords;-cannot serve-as,the
sole basis for requiring a WA Determination:�.Bacic-upfieldsznustbe=ted inthe-commentzectionand milstbe accessible
by irrigation -system.
Part IV. Pending WA Determinations -
P2
Plan • lacks.followinginformation: Lit-Y46l4 aCrc We�c1,n F'1016�s��(
e,* IV ­ Ileod
Plan revision -may.-satisfy-75% rule based on adequate overall PAN deficit and by 4 Gr-r-S
adjusting -all field:acreage_to below 75% use rate
P3 Other (ielin process of installing new irrigation system):

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
Marty Blizzard
Mary Blizzard #2
141 N. Blizzard Town Road
Beulaville NC 28518
Dear Marty Blizzard:
A M.?WA
IT4 0
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT ANo NATURAL RE50URCE5
December 30, 1999
Subject: Fertilizer Application Recordkeeping
Animal Waste Management System
Facility Number 31-828
Duplin County
This letter is being sent to clarify the recordkeeping requirement for Plant Available Nitrogen (PAN)
application on fields that are part of your Certified Animal Waste Management Plan.
In order to show that the agronomic loading rates for the crops being grown are not being exceeded, you
must keep records of all sources of nitrogen that are being added to these sites. This would include nitrogen
from all types of animal waste as well as municipal and industrial sludges/residuals, and commercial fertilizers.
Beginning January 1, 2000, all nitrogen sources applied to land receiving animal waste are required to
be kept on the appropriate recordkeeping forms (i.e. IRR1, IRR2, DRY1, DRY2, DRYS, SLUR1, SLUR2,
SLDI, and SLD2) and maintained in the facility records for review. The Division of Water Quality (DWQ)
compliance inspectors and Division of Soil and Water operation reviewers will review all recordkeeping during
routine inspections. Facilities not documenting all sources of nitrogen application will be subject to an
appropriate enforcement action.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Ms. Sonya Avant of the
DWQ staff at [phone] ext. 571.
9�i
cc: Wilmington Regional Office
Duplin County Soil and Water Conservation District
Facility File
Sincerely,
Kerr T. Stevens, Director
Division of Water Quality
1617 Mail Service Center, Raleigh, North Carolina 27699.1617 Telephone [phone] Fax [phone]
An Equal Opportunity AMrmative Action Employer 50% recycled/10% post -consumer paper

State of North Carolina
Department of Environment,
Health and Natural Resources
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
November 13, 1996
Marty Blizzard
Mary Blizzard #2
141 N. Blizzard Town Road
Beulaville NC 28518
SUBJECT: Operator In Charge Designation
Facility: Mary Blizzard #2
Facility ID#: 02$
Duplin County .
Dear Mr. Blizzard:
Senate Bill 1217, An Act to Implement Recommendations of the Blue Ribbon Study
Commission on Agricultural Waste, enacted by the 1996 North Carolina General Assembly,
requires a certified operator for each animal waste management system that serves 250 or more
swine by January 1, 1997. The owner of each animal waste management system must submit a
designation form to the Technical Assistance and Certification Group which designates an
Operator in Charge and is countersigned by the certified operator. The enclosed form must be
submitted by January 1, 1997 for all facilities in, operation as of that date. Failure to designate a
certified operator for your animal waste management system is a violation of 15A NCAC 2H
.0224 and may result in the assessment of a civil penalty.
If you have questions concerning operator training or examinations for certification, please
contact your local North Carolina Cooperative Extension Service agent or our office.
Examinations have been offered on an on -going basis in many counties throughout the state for
the past several months and will continue to be offered through December 31, 1996.
Thank you for your cooperation. If you have any questions concerning this requirement please
call Beth Buffington or Barry Huneycutt of our staff at 91gn33-0026.
Sincerel ,
A. Preston Howard, Jr., P.E., Director
Division of Water Quality
Enclosure
cc: Wilmington Regional Office
Water Quality Files
P.O. Box 27687, �1���
Raleigh, North Carolina 27611-7.687 r� An Equal Opportunity/Affirmative Action Employer
Voice 919-715-4100 5M recycled/ 10°k post -consumer paper

State of North Carolina
Department of Environment,
Health and Natural Resources
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
Marty Blizzard
Mary Blizzard #2
141 N. Blizzard Town Road
Beulaville NC 28518
e��
EDE-:=HNF;Z
November 13, 1996
SUBJECT: Operator In Charge Designation
Facility: Mary Blizzard #2
Facility ID#: Ni928=?
Duplin County
Dear Mr. Blizzard:
Senate Bill 1217, An Act to Implement Recommendations of the Blue Ribbon Study
Commission on Agricultural Waste, enacted by the 1996 North Carolina General Assembly,
requires a certified operator for each animal waste management system that serves 250 or more
swine by January 1, 1997. The owner of each animal waste management system must submit a
designation form to the Technical Assistance and Certification Group which designates an
Operator in Charge and is countersigned by the certified operator. The enclosed form must be
submitted by. January 1, 1997 for all facilities in operation as of that date. Failure to designate a
certified operator for your animal waste management system is a violation of 15A NCAC 2H
.0224 and may result in the assessment of a civil penalty.
If you have questions concerning operator training or examinations for certification, please
contact your local North Carolina Cooperative Extension Service agent or our office.
Examinations have been offered on an on -going basis in many counties throughout the state for
_the past several months and will continue to be offered through December 31, 1996.
Thank you for your cooperation. If you have any questions concerning this requirement please
call Beth Buffington or Barry Huneycutt of our staff at 91gn33-0026.
Sincerel ,
A. Preston Howard, Jr., P.E., Director
Division of Water Quality
Enclosure
cc: Wilmington Regional Office
Water Quality Files
P.O. Box 27687, 1r��
Raleigh, North Carolina 27611-7687 �� An Equal Opportunity/Affirmative Action Employer
Voice 919-715-4100 50% recycled/ 100k post -consumer paper