820381_CORRESPONDENCE_20171231

NORTH CAROLINA
Department of Environmental Qual

DENR-FRC
APR 0 4 2os
NCDENR
North Carolina Department of Environment and Natural Resources
Pat McCrory
Governor
Marshall S Horne
Marshall Horne Farm
2595 Lamb Rd
Garland, NC 28441-8215
Dear Marshall S Horne:
Division of Water Quality
Charles Wakild, P.E.
Director
April 2, 2013
0wo
John E. Skvarla, III
Secretary
Subject: Certificate of Coverage No. AWS820381
Marshall Horne Farm
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
In accordance with your April 2, 2013 request to change operation type without exceeding the permitted
steady state live weight, we are hereby forwarding to you this Certificate of Coverage (COC) issued to
Marshall S Horne, authorizing the operation of the subject animal waste management system in
accordance with General Permit AWG 100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for the Marshall Horne Farm, located in Sampson County, with a swine animal capacity
of no greater than the following annual averages:
Wean to Finish: Feeder to Finish: 1603 Boar/Stud:
Wean to Feeder: Farrow to Wean: Gilts:
Farrow to Finish: Farrow to Feeder: Other:
If this is a Farrow to Wean or Farrow to Feeder operation, there may be one boar for each 15 sows. Where
boars are unnecessary, they may be replaced by an equivalent number of sows. Any of the sows may be
replaced by gilts at a rate of 4 gilts for every 3 sows.
The COC shall be effective from the date of issuance until September 30, 2014, and shall hereby void
Certificate of Coverage Number AWS820381 dated October 1, 2009. Pursuant to this COC, you are
authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must- be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Please p4ycarefW attention to the
record keeping and monitoring conditions in this permit. Record keeping forms are unchanged with this
General Permit. Please continue to use the same record keeping forms.
1636 Mail Service Center, Raleigh, North Carolina 27699-1636
Location:512 N. Salisbury St. Raleigh, North Carolina 27604
Phone: [phone] PAX: 919-807-6492
Internet: www.ncwatergualitv.om
One
NorthCarolina
Al
An Equal Opportunity 1 Affirmative Action Employer

If your Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Per 15A NCAC 2T .0105(h) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100-foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and- injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, then an application for renewal must be.filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Unit for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition 11.22 of the General Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Tropical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You
may find detailed watch/warning information for your county by calling the Raleigh, NC National
Weather Service office at [phone], or by visiting their website at: www.erh.noaa.goy/er/rah/
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Aquifer Protection Staff may be reached at [phone]. If you need additional information
concerning this COC or the General Permit, please contact the Animal Feeding Operations Unit staff at
[phone].
Sincerely,
for Charles Wakild, P.E.
cc: (Certificate of Coverage only for all ccs)
Fayetteville Regional Office, Aquifer Protection Section
Sampson County Health Department
Sampson County Soil and Water Conservation District
APS Central Files (Permit No. AWS820381)
AFO Notebooks

State of North Carolina
Department of Environment and Natural Resources
Division of Water Quality
Animal Waste Management Systems
Request for Certificate of Coverage
Facility Currently Covered by an Expiring State Non -Discharge General Permit
F 2, 0391
On September 30, 2009, the North Carolina State Non -Discharge General Permits for Animal Waste Management Systems will
expire. As required by these permits, facilities that have been issued Certificates of Coverage to operate under these State Non -
Discharge General Permits must apply for renewal at least 180 days prior to their expiration date. Therefore all applications must be
received by the Division of Water Quality by no later than April 3, 2009.
Please do not leave any quesdon nnanswnvA Please make any necessary corrections to the data below
1. Facility Number: 820381 and Certificate of Coverage Number_ AWS820381
2. Facility Name: Marshall Horne Farm
3. Landowner's name (same as on the Waste Management Plan): Marshall S Horne
4. Landowner's Mailing address: 2595 Lamb Rd
City/State: Garland, NC Zip: 28441
Telephone Number (include area code): 5299281 Fr=W.-
5. Facility's physical address:
City/State:
5. County where facility is located: Sampson
EIVED
JUL Of
bpi-FAYETtE11 imalAU a
Zip: nl��
7. Farm Manager's name (If different than the Landowner): 501YI tiel M . jb,ne
8. Farm Manager's telephone number (include area code): q - 5 a� - tr (ig
9. Integrator's name (if there is not an integrator write "None"): Garland Farm SussMly
10. Lessee's name (if there is not a lessee write "None"): J an-f -
11 _ Indicate animal operation type and number. F Q t mw 4-o wean MO
Swine
Cattle
l}ry Poultry
Wean to Finish
Dairy Calf
Non Laying Chickens
Wean to Feeder
Dairy Heifer
Laying Chickens
Farrow to Finish
Milk Cow
Turkeys
Feeder to Finish
Dry Cow
Other
Farrow to Wean 500
Beef Stocker Calf
Pullets
Farrow to Feeder
Beef Feeder
Turkey Poults
Boar/Stud
Beef Brood Cow
Gilts
Other
Other
Wet Poultry
Horses - Horses
Sheep - Sheep
Non Laying Pullets
Horses - Other
Sheep - Other
Layers
>Jnua,r 1DV7UV v w r n-rian

Submit two (2) copies of the most recent Waste Utilization Plan for this facility with this application. The Waste Utilization
Plan must be signed by the owner and a technical specialist. if a copy of the facility's most recent Certified_ Animal Waste
Manasement Plan CAWMP) has not previously been submitted to the NC Division of Water OuaGty. two (2) copies of the
CAWMP must also be submitted as part of this application.
I attest that this application has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that. if
all required parts of this application are not completed and that if all required supporting information and attachments are not included.
this application package will be returned to me as incomplete. Note: In accordance with NC General Statutes 143-215.6A and 143-
215.613, any person who knowingly makes any false statement, representation, or certification in any application may be subject to
civil penalties up to $25,000 per violation. (18 U.S_C_ Section 1001 provides a punishment by a fine of not more than S10,000 or
imprisonment of not more than 5 years, or both for a similar offense.)
Printed Name of Signing Official (Landowner, or if multiple Landowners all landowners should sign- If Landowner is a corporation,
signature should be by a principal L-xecutive officer of the corporation):
Name: frY/ j 1 �' / ��L , �.� Title: 17
Signature: _% ~/ �- Date:
Name:
Title:
Signature:
Date:
Name:
Title:
Signature:
Date:
THE COMPLETED APPLICATION SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NCDENR — DWQ Animal Feeding Operations Unit
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
Fax Number: [phone]
FORM RENEWAL -STATE GENERAL 02/09

'Me Irrigation Application Factors for each field in this plan are shown in the following table. Infiltration
rate varies with soils. If applying waste nutrients through an irrigation system you must apply at a rate
that will not result in runoff. This table provides the nmxirnum application rate per hour that may be
applied to each field selected to receive wastewater. It also lists the nlaxinnlm application amount that
each field may receive in any one application event.
Irrigation Application Factors
Tract
Field
Soil Series
Application Rate
(inch-bo-)
Application Anxwm
(ftKt s)
4481
ZONE 1
Goldsboro
0.50
0-96
4481
ZONE 2
Autryville
0.60
0.72
-----------------------------------------------------=------------------------------
764326 Database Version 2.0 Date Pnnied.- 06-21-2002 lAF Page 1 of 1

The following Lagoon Sludge Nitrogen Utilization table provides an estimate of the number of acres needed for
sludge utilization for the indicated acciindation period These estimates are based on avedage nitrogen
concentrations for each source, the number of animals in the facility and the plant available nitrogen application rates
shown in the second column.
Lagoon sludge contains nutrients and organic matter remaining after treatment and application of the effluent. At
clean out, this material nuist be utilized fDr crop production and applied at agronomic rates- In most cases, the
priority nutrient is nitrogen but other nutrients including phosphorous, copper and zinc can also be lirsi{ting. Since
nutrient levels are generally very high, application of sludge twist be carefully applied -
Sites must first be evaluated for their suitability for sludge application. Ideally, effluent spray fields should not be
used for sludge application- If this is not possible, care should be taken not to load effluent application fields with
high amounts of capper and zinc so that additional elflt=it cannot be applied On sites vulnerable to surface water
moving to stream and lakes, phosphorous is a concern. Soils containing very high phosphorous levels may also be a
concern.
Lagoon Sludge Nitrogen Utilization Table
Crop
Maximum
PA-N Rate
Ib/ac
Mwdmum Sludge
Application Rate
1000 gal/ac
Minimum Acres
5 Years Accumulation
Minimum Acres
10 Years Accumulation
Minimum Acres
15 Years Accumulation
Swine Farrowing-Weanling Lagoons Sludge - Standard
Corn 120 bu
150
13.16
14-82
29.63
44.45
Hay 6 ton RY.E.
300
26-32
7.41
14.82
22.22
Soybean 40 bu
160
14.04
13.89
27.78
41.67
------------------------------------------------------------------------------------------------ -----
764326 Database Version 2.0 Date Printed: 06-21 2002 Sludge Page 1 of 1

The Available Waste Storage Capacity table provides an estimate of the number of days of storage
capacity available at the end of each month of the plan Available storage capacity is calculated as the
design storage capacity in days minus the number of days of net storage volume accutrwlated. The start
date is a value entered by the user and is defined as the date prior to applying nutrients to the first crop in
the plan at which storage volume in the lagoon or holding pond is equal to moo.
Available storage capacity should be greater than or equal to zero and less than or equal to the design
storage capacity of the facility. If the available storage capacity is greater thanthe desigrt storage capacity,
this indicates that the plan calls for the application of nutrients that have not yet accumulated. If available
storage capacity is negative, the estimated volume of accumulated waste Proceeds the design storage volume
of the structure. Either of these situations indicates that the planned application interval in the waste
utilization plan is inconsistent with the structure's temporary storage capacity.
Available Waste Storage Capacity
Source Name
Swine Farrowing-Weanling Lagoon Liquid
Design storage Capacity (Days)
Start Date
9/30
180
Plan Year
Month
Available Storage Capacity (Days)
1
1
107
1
2
93
1
3
147
1
4
180
1
5
180
1
6
180
i
7
180
1
8
180
1
9
180
1
10
159
1
11
139
1
12
113
* Available Storage Capacity is calculated as of the end of each month
------------------ --------------------
764326 Database Version 2.0 Date Printed: 06-21-2002 Capacity Page 1 of 1

Required Specifications For Animal Waste Management
1. Animal waste shall not reach surface waters of the state by runoff, drift,
manmade conveyances, direct application, or direct discharge during
operation or land application. Any discharge of waste that reaches surface
water is prohibited.
2. There must be documentation in the design folder that the producer either
owns or has an agreement for use of adequate land on which to properly
apply the waste. If the producer does not own adequate land to properly
dispose of the waste, he/she shall provide evidence of an agreement with a
landowner, who is within a reasonable proximity, allowing him/her the use
of the land for waste application_ It is the responsibility of the owner of the
waste production facility to secure an update of the Nutrient Management
Plan when there is a change in the operation, increase in the number of
animals, method of application, receiving crop type, or available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs
for realistic -crop yields based upon soil type, available moisture, historical
data, climatic conditions, and level of management, unless there are
regulations that restrict the rate of applications for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre per
year. Waste may be applied to land eroding at more than 5 tons per acre per
year but less than 10 tons per acre per year provided grass filter strips are
installed where runoff leaves the field (see USDA, MRCS Field Office
Technical Guide Standard 393 - Filter Strips]
5. Odors can be reduced by injecting the waste or by disldng after waste
application. Waste should not be applied when there is danger of drift from
the land application field.
6. When animal waste is to be applied on acres subject to flooding, waste will
be soil incorporated on conventionally tilled cropland. When waste is
applied to conservation tilled crops or grassland, the waste may be
broadcast provided the application does not occur during a season prone to
flooding (see "Weather and Climate in North Carolina" for guidance).
-----------------------------------------------------_ ---------------------------------------
764326 Database Version 2.0 Dale Printed: 06-2 t-2002 Specification Page 1 a.

7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate
such that runoff does not occur offsite or to surface waters and in a method
which does not cause drift from the site during application. No ponding
should occur in order to control odor and flies.
S. Animal waste shall not be applied to saturated soils, during rainfall events,
or when the soil surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner
that the crop is not covered with waste to a depth that would inhibit growth.
The potential for salt damage from animal waste should also be considered.
10. Nutrients from waste shall not be applied in fall or winter for spring planted
crops on soils with a high potential for leaching. Wastelnutrient loading
rates on these soils should be held to a minimum and a suitable winter cover
crop planted to take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking dormancy.
11. Any new swine facility sited on or after October 1,1995 shall comply with
the following: The outer perimeter of the land area onto which waste is
applied from a lagoon that is a component of a swine farm shall be at least
50 feet from any residential property boundary and canal. Animal waste,
other than swine waste from facilities sited on or after October 1, 1995, shall
not be applied closer that 25 feet to perennial waters.
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other
than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and public
right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or
wetlands by a discharge or by over -spraying. Animal waste may be applied
to prior converted cropland provided the fields have been approved as a
land application site by a "technical specialist". Animal waste shall not be
applied on grassed waterways that discharge directly into water courses,
and on other grassed waterways, waste shall be applied at agronomic rates
in a manner that causes no runoff or drift from the site.
---------------------------------------------------------------. ----------------------------------
764326 Database Version 2.0 Date Printed: 06-21-2002 Specification Page 2 0:

16. Domestic and industrial waste from washdown facilities, showers, toilets,
sinks, etc., shall not be discharged into the animal waste management
System.
17. A protective cover of appropriate vegetation will be established on all
disturbed areas (lagoon embankments, berms, pipe runs, etc.). Areas shall
be fenced, as necessary, to protect the vegetation. Vegetation such as trees,
shrubs, and other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible. Berms
and structures should be inspected regularly for evidence of erosion,
leakage, or discharge.
18. If animal production at the facility is to be suspended or terminated, the
owner is responsible for obtaining and implementing a "closure plan" which
will eliminate the possibility of an illegal discharge, pollution, and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected on
a regular basis to prevent breakdowns, leaks, and spills. A regular
maintenance checklist should be kept on site_
20. Animal waste can be used in a rotation that includes vegetables and other
crops for direct human consumption. However, if animal waste is used on
crops for direct human consumption, it should only be applied pre -plant
with no further applications of animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and bottom
elevations of the temporary storage (pumping volume) of all waste
treatment lagoons. Pumping shall be managed to maintain the liquid level
between the markers. A marker will be required to mark the maximum
storage volume for waste storage ponds.
--- -----------------------------------------------------------------------------
764326 Database Version 2.0 Date Printed: 06-21-2002 Specification Page 3 o

22. Waste shall be tested within 60 days of utilization and soil shall be tested at
least annually at crop sites where waste products are applied. Nitrogen
shall be the rate -determining nutrient, unless other restrictions require
waste to be applied based on other nutrients, resulting in a lower application
rate than a nitrogen based rate. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for
optimum crop production Soil and waste analysis records shall be kept for
a minimum of five years. Poultry dry waste application records shall be
maintained for a minimum of three years. Waste application records for all
other waste shall be maintained for a minimum of five years.
23. Dead animals will be disposed of in a manner that meets North Carolina
regulations.
--------------------------------------------------------------_-------------
764326 Database Version 2.0 Date Printed: 06-21-2002 Specification Pag e 4 o.

Crop Notes
The following crop note applies to field(s): ZONE 1
Bermudagrass Coastal Plain, Mineral Soil, Poorly Drained to Somewhat Poorly Drained.
Adaptation: Effective artificial drainage MUST be in place to achieve Realistic Yield Expectations
provided for these soils.
In the Coastal Plain, hybrid bermudagrass sprigs can be planted Mar. 1 to Mar. 31. Cover sprigs 1" to 3"
deep (1.5" optimal)_ Sprigs should be planted quickly after digging and not allowed to dry in sun and wind.
For Coastal and Tifton 78 plant at least 10 bu/ac in 3' rows, spaced 2' to 3' in the row. Generally a rate of
30 bu/ac is satisfactory to produce full groundcover in one or two years under good growing conditions_
Tifton 44 spreads slowly, so use at least 40 bu/ac in 1.5' to 2' rows spaced V to 1.5' in row. For
broadcast/disked-in sprigs use about 60 bu/ac. Soil test for the amounts of lime. phosphorus, potassium
and micronutrients to apply preplant and for annual maintenance. Apply 60 to 1001b/ac N in the
establishment year in split applications in April and July. For established stands apply 180 to 240 lb/ac N
annually in split applications, usually in April and following the first and second hay cuts. Reduce N rates
by 25% for grazing. Refer to NCSU Technical Bulletin 305 Production and Utilization of Pastures and
Forages in North Carolina for more information or consult your regional agronomist or extension agent ivr
assistance.
The following crop note applies to field(s): ZONE 2
Bermudagrass Coastal Plain; Mineral Soil, Moderately Well Drained_
Adaptation: Well -adapted -
In the Coastal Plain, hybrid bermudagrass sprigs can be planted Mar. 1 to Mar. 31. Cover sprigs 1" to 3"
deep (1.5" optimal). Sprigs should be planted quickly after digging and not allowed to dry in sun and wind.
For Coastal and Tifton 78 plant at least 10 bu/ac in 3' rows, spaced 2' to 3' in the row. Generally a rate of
30 bulac is satisfactory to produce full groundcover in one or two years under good growing conditions.
Tifton 44 spreads slowly, so use at least 40 bu/ac in 1.5' to 2' rows spaced I' to 1.5' in row. For
broadcast/disked-in sprigs use about 60 bu/ac. Soil test for the amounts of lime, phosphorus, potassium
and micronutrients to apply preplant and for annual maintenance. Apply 60 to 1001b/ac N in the
establishment year in split applications in April and July. For established stands apply 180 to 240 lb/ac N
annually in split applications, usually in April and following the first and second hay cuts. Reduce N rates
by 25% for grazing. Refer to NCSU Technical Bulletin 305 Production and Utilization of Pastures and
Forages in North Carolina for more information or consult your regional agrmarrust or extension agent for
assistance.
---------------------------------------------------------------P ----
764326 Database Version 2.0 Date Printed: 06-21-2002 C Note Page 1 of

The following crop note applies to field(s): ZONE 1
Small Grain: CP_ Mineral Soil. low -leachable
In the Coastal Plain oats and barley should be planted from October 15-October 30; and rye from October
I5-November 20. For barley, plant 22 seed/drill row foot and increase the seeding rate by 5% for each
week seeding is delayed beyond the optimum time. See the seeding rates table for applicable seeding rate
modifications in the current NCSU "Small Grain Production Guide". Also, increase the initial seeding rate
by at least 10% «vhen planting no -till. Oats should be planted at 2 bushels/acre and rye at 1-1 1/2
bushelslacre. Plant all these small grains at 1-1 1/2" deep. Adequate depth control is essential. Review the
NCSU Official Variety "green book" and information from private companies to select a high yielding
vanety %%ith the characteristics needed for your area and conditions. Apply no more than 30 lbs/acre N at
planting. Phosphorus and potash recommended by a soil test can also be applied at this time. The
remaining N should be applied during the months of February -March.
The following crop note applies to field(s): ZONE 2
Small Grain. CP. Mineral Soil, medium leachable
In the Coastal Plain, oats and barley should be planted from October 15-October 30; and rye from October
15-November 20. For barley, plant 22 seed/drill row foot and increase the seeding rate by 5% for each
week seeding is delayed beyond the optimum time. See the seeding rates table for applicable seeding rate
modifications in the current NCSU "Small Grain Production Guide". Also, increase the initial seeding rate
by at least 10% when planting no -till. Oats should be planted at 2 bushels/acre and rye at 1-1 1/2.
bushels/acre, Plant all these small grains at 1-1 1/2" deep- Adequate depth control is essential. Review the
NCSU Official Variety "green book" and information from private companies to select a high yielding
variety with the characteristics needed for your area and conditions- Apply no more than 30 lbs/acre N at
planti�g. Phosphorus and potash recommended by a soil test can also be applied at this time. The
remaining N should be applied during the months of February -March.
------------------------------------------------------------- g-------
764326 Database Version 2.0 Date Printed: 06-21-2002 CropNote Page 2 of

WASTE UTILIZATION PLAN AMENDMENT
This amendment is included to address the wastewater that may need to be pumped, for
maintenance purpose, from the abandoned lagoon_
Lagoon # _ Surface Area
0.60 Acres
Rainfall in excess of evaporation during 12 month period in Sampson County = 11.23
inches (0.94 foot)(From Rainfall -Evaporation Chart for Area 3).
Volume of Rainfall to be Pum ed From Abandoned Lagoon
1 = 182,982.65 gallons
PAN from Waste Analysis Report for Abandoned Lagoon = 0.15 N/1000 gallons.
Total PAN from the abandoned lagoon that may need to be applied per year for
maintenance = 27.4 lbs N.
The PAN deficit from the existing waste utilization plan is (-721 lbs N). The new deficit
is (-693.61bs N)_ Therefore, there is adequate land included in the existing waste
utilization plan to treat the wastewater pumped, for maintenance, from the abandoned
lagoon.
45�MCO-Z-
AL SPE/�- '7' 9 -
1ALIST DATE

WETTABLE ACRES
DETERMINATION
MARSHALL HORNE
MARS HALL H O RN E FARMS
82-381
2595 LAMB ROAD
GARLAND, N.C. 28441
COMPLETED .BY-
SAMPSON COUNTY SOIL &
STATER CONSERVATION
DISTRICT
84 COUNTY COMPLEX ROAD
CLINTON, N.C. 28328
[phone] EXT. 3

Wettable Acres Determination Certification
Name of Facility:
AjU 11.4[_L
Z✓C �
Facility Number: $Z - 361
Owner(s) Name:
�}QS klr+c LL
11r✓6
Phone No: '710-52. 9 -gab J
Mailing Address:
Z�yS C AMb
14,9�a
I L Z 941/ 1
By signing this force, the facility owner and Technical Specialist acknowledge the completion of the
Wettable Acres Determination. All necessary Wettable Acre Determination Field Data Sheets and
calculations were completed to conduct a Wettable Acre Determination. The facility's Waste
Utilization Plan has been amended as necessary to reflect actual wetted acreage. A copy of all
worksheets, calculations, and other Wettable Acres Determination documents, along with the
applicable Waste Utilization Plan and Wettable Acre Determination Certification will be filed with
the local Soil and Water Conservation District A copy will also be kept on site with the Certified
Animal Waste Management Plan. Any future modifications must be approved by a technical
specialist and filed with the Soil and Water Conservation District prior to implementation. If any
modifications to the existing irrigation system or any new irrigation equipment was required to
adequately address the waste management needs of this facility; an Irrigation Specialist or
Professional Engineer has certified the design and installation below.
Owner Name: A4AeSjAALL �60jr
Owner Signature:
Technical Specialist Name: /1�1jjjjfAjn, J
Date:
Technical Specialist Signature: Date: 7 — %OZ
If assisted by an Irrigation Specialist or Professional Engineer please read and sign below:
Animal waste application equipment has been designed or modified to apply waste as necessary to
accommodate the waste management plan and according to NRCS Standards. Animal waste
application equipment has been installed according to MRCS Standards and is ready for use.
Irrigation Specialist/PE Name:
Irrigation Specialist/PE Signature: Date:
Submit this form to:
Attn: Sonya Avant
Non -Discharge Compliance Unit
Division of Water Quality
1617 Mail Service Center
WADC — 7,1109

r ya Ad Acreage Determination Procedures
for Wastewater Application Equipment
STATIONARY SPRINKLER SYSTEM
FIELD DATA WORKSHEET *
I. Sprinkler make and model number
5 �'
2_ Sprinkler nozzle size'*2 a NbZ2i-E /116 [inch!
3. Lateral spacing ^ So [feet] by sprinkler spacing along lateral so [feet]
4. Operating pressure at the sprinkler 3S- [psi]
S. Sprinkler wetted diameter i 11 [feet]. measured or determined from chart_
5. Number of sprinklers operating at one time I b
7. Total number of sprinklers or sprinkler locations in the system
Exterior sprinklers:
full circle
part circle
Interior sprinklers:
S LI
full circle
Sprinkler locations permanently marked.
✓� _ yes _
_ no
8.
Supply line y
Permanent pipe
Portable pipe
"9.
Lateral lute size
[inch]. If there is more than one size, indicate the size and
approximate length of each. Can be done on the
map.
'Ifl.
Lateral line length _ _
[feet}. (Longest lateral)
_ .,_
*`11_
Supply line size _ _
[inch]. If there is more than
one size, indicate the size and
approximate length of each. Can be done on the
map.
-12.
Supply Line length
[feet].
Maximum pumping distance.
'* 13.
Pump make and model number
'*14.
Pump capacity
- - - Iurnl
_ � �.�
**15.
Engine make and model number
_ _ _
- , or
-16.
Electric motor horsepower and rpm _
_ _ _ [hp]
_ [rpm]
Note: It is strongly recommended that you field measure the sprinkler wetted diameter- You should do this on the
longest lateral about half -way down the lateral.
* Locate each sprinkler or sprinkler location on the map_ Indicate whether it is full circle or part circle. Show the
location of the supply line. Irrigated acres are determined by lateral line, by zone, or by field_
Optional data, furnish where possible
"* Information furnishiby /
and/or 5v _
Signature of owner or facility representative Si r_ature of technical sp baust
%
Printed name of owner or facility representative Printed//name of technical specialist
Date Date fp 20 - crz-
Only the Verson or people collecting the data should sign the Field Data Worksheet.
S

ricatCd Acreage Determination Procedures
`or Wastewater Application Equipment
STATIONARY SPRINKLER /GUN SYSTEM
WETTABLE ACRE COMPUTATIONAL WORKSHEET
1. Farm number (identification) 440;Mt•L-"F- Field nurnber (identification)
3. Irri111,
gation system designation Existing irrigation system
New/expanded irrigation systern
3. Number of stationary sprinklers Jr n Interior sprinklers 3 2— s Exterior sprinklers
4. Wetted diameter [feet] horn Field Data Worksheet
S. Spacing lan Sprinkler spacing along lateral [feet]
w $b Sprinkler spacing as a percentage of wetted diameter
6. Sprinkler pattern /Multiple laterals Single lateral
t/ Excessi,.ely spaced sprinklers
7. Read the irrigated area per sprinkler for the given wetted diameter from the appropriate table and
column based on pattern, spacing, and spunkier Iot-ation-
0• 133 Acres per interior sprinkler :tom
U )33 Acres per exterior sprinkler from
Table +v Column
lum
Table Cilllalal
8. 11-lultiply the tabulated irrigated acreage .value per sprinker by the number of sprinklers of each
categonr in the Meld. Add all of these. The sum is the total irrigated acreage for the field.
Dad 3 3 (a) Acres per ;nte:-ior sprinkler X 1 #1 # Sprinklers �• 113 Acres
D' 33 (b) Acres per exterior spr;nkler X 18 r Sprinkle-s -- Z• 39Y acres
/a' S677Totai wettable acres for field (Sum: 8a + 8b)
Wettable acre Computational Worksheet completed by: Date: 6
Si atute of teci;nicai sp, ialist
L
�6`

FjQ e C tW--6 �
f i / U.S. - Diane (lest) METFUC - Dtmneter (Matins)
SPRNKLER (psi) 35 f 40 45 6o 56 60 65 70 (bar) 2-5 3.0 3-5 4.0 45 5.0
BASE PRESSWE (µsr] 3f 25 43M 50.75 MOO 6 -25 7250
114 [+bozos - grmn
Fbw Opm)
8.11
8-66
920
9.W
to-2
10.6
11.0
115
Diem. at 1 S height (tt)
106
ill
113
115
117
119
121
123
Diam. at 6A' height (1t)
114
118
121
124
126
128
129
130
#16 Nanda - 014')
Flow (gpm)
10.7
11.4
12.1
12.8
13-4
14.0
14.6
15-1
Diam. at 1.5- tidgM (Si)
111
117
120
123
126
129
131
133
Diam. at 6A' height (R)
122
125
129
131
134
136
137
138
#W Nozzie - (W32")
Flow (gpm)
DIW- at 1 S' height (iZ)
Diem- at GO height (8)
133
118
128
142
124
132
15-0
IV
136
159
129
137
16.6
134
141
17.4
139
144
18.1
142
146
18A
144
147
irm Naor4e. g
F?r!,r(gpm) : { ; `.; 162
17.1
182
192
20-1
21.0
212
22.7
130
134
137
142
146
150
153
Diam. at 6.0' height (n)
133
137
140
143
147
151
154
155
#22 Nozzle - (11rlt2 )
Flow (gpm)
19.3
20.5
21.8
22.9
24.1
25.1
20.1
27.1
Diann- at I height (tt)
126
133
141
148
153
157
160
162
Diarn. zA SAY height (R)
136
141
146
ISO
155
159
162
164
#14 Notes - (5.6 Run)
(LIS)
0S2
057
0-61
0.66
0.70
0.73
0.5 m (m)
32.7
34.3
35.1
36.0
WS
37A
2.0 m (m)
35.1
36.6
37.9
38.8
39.3
39.8
416 Nozzle - (&4 mm)
(LIS)
0.69
O.7S
0b1
037
0.92
0.97
0-5 m (m)
34.3
35.3
37.6
39-0
40-0
41.0
2.0 m (m)
37.5
39.0
40.1
412
41.8
42-2
#18 Nozzle - (7.1 mm)
(LIS) 0.85 094 1.01 1.08 1-15 121
0.5 m (m) 36A 38.4 395 41.8 43.3 44S
2-0 m (m) 393 40.9 419 43.5 44S 45.0
i140 Nozzie - (79 mm)
(LIS) 1.02 1.12 121 129 137 1.45
0.5 m (m) 38.3 40.5 42-0 ".0 45.8 47.1
2.0 m (m) 40.8 42.4 43.8 45.5 47.0 47.4
#= Nozzle - QL7 tun)
(Us) 1.23 1.34 1.45 1 S5 1.65 1.73
0.5 m (m) 38.9 422 452 47.4 483 49.8
2.0 m (m) 41.8 44.0 46-0 48.0 49.4 SOLI
#24 Ncz da - (8! ') #24 Nozzle - (9S mm)
Flow (gpm) 22.4 232 25.3 26.7 28.0 29.3 30.4 31.6 (LIs) 1-43 ls6 1.69 1.80 1.91 2.02
Dian, at 1 S height (it) 130 138 145 151 156 160 166 169 0.5 m (m) 402 43.6 46.3 48.3 50.7 52.4
Diam. at 6.0` height (tt) 138 145 150 155 ISO 164 167 170 2-0 m (m) 42.6 45.3 475 49.5 50.9 524
Fgrees reflect a+Ctuaf lest afiW QbWomdWa&dwl corx§W s: SM-n heights r-W from a.5 - f--,S ft (2.6 - 4.7m) above Hero** based an
pr6.ssias arrd nOzd8 AcW. SprrraH®rperfarrrrarrrae tests were condurbdar accont>arrce wro on Ama7cm SodW ofAgnr..LAWa l
sranbrri SMW Y and are rgpAmernapve ofpmducWn at the cane of pvb✓,icab o L Ommeters shown are krslan and szaight bom names and
eriRuerrt van as (bnM"). G4'frerrr zits and/or carte Cant Vlmk its are avar7aAule• ca vuR & amy bor*mofc periaffrhv ce daW
Sav*lger lm7 rafion (407J-2W--5555- 00-70EFF-9

21-JUM-2002 10:46 FROM-KCDENR FRO 9104860707 T-681 P-002/002 F-123
�N,ELS NP35/65 PERFORMANCE DATA 1h
MODEL P35 (Port Circle) -314;"WI VANE -27`TRA.lECTORY-1Dc:agalhorcdE�m=Fx;rklaronlz'i�:or-��nc�
11/W 3r16• 13164' 79r
BASE
CPUua
r�
GRM
iA!>.
G?II
lrAl}
FE
1,7{1
na
�t
szlt
eat
30
3.9
Al
4.6
44
5.5
44
6.5
46
7.5
46
35
4.2
42
5.0
45
6.0
45
7-0
47
8.0
48
40
4.5
43
5-3
46
8.4
47
75
48
8.6
52
45
4.75
4A
f 5.4
47
6.8
48
8-0
49
93
53
50
4.9
45
6.0
48
1 7.2
49
j 8.4
50
9.6
54
55
5.2
46
6.3
49
7 S
49
8-8
51
10.0
54
60
5.4
47
6.6
50
7.9
50
9.1
54
10S
SS
65
5.6
48
6.9
50
e_2
51
9,5
54
10.9
56
70
5.8
49
7.1
51
&a
52
9.8
55
11.3
57
75 }
6-1
50
7.4
52
8.8
52
10.77
55
17A
57
80
6.3
51
7-6
52
9.1
53
70.5
56
12.1
58
KO D EL PL}O (Pt.rt Circle} 1' W/ VANE - 24- TRAJECTORY - (Dom gari erct Imm sp inider on 18• ,iser - no wirwi
114" lar 19161' Jl6' 211W 11C!:' WMI 1w
BASE
r�9
wx
RAA
Grsl
M0.
FLW14
f;AA.
f1
17`ll
iRa
FT.
6Pi1
7AQ
FE
Eryt
LJID
K
fiPa
na
w
RAR
ft
:3F1
0
7.6
51
1 9.9
53
17.4
56
13.7
57
15.3
57
16.5
59
18.0
60
l 19.6
61
71-0
62
35.
1 9-2
53
10.7
55
13.4
58
14.7
59
16.4
60
17.8
62
19.4
62
} 21.0
63
22.6
65
s0
6.8
55
11.5
57
14.4
61
;5.7
c3
17.7
63
19.1
65
20.8
65
22.6
66
24.3
68
45
4.3
57
12.1
59
15.1
bz
16.7
6+
58.7
65
20.2
67
22.0
67
23.9
68
2S.7
70
50
1 9.8
59
17.8
62
15.9
54
17.7
67
1 19.7
67
21.3
64
1 23.3
70
25.3
71
27.1
73
55
10-3 _
60
13.5
63
16.8
66
13.5
68
2e.7
69
22.3
71
74.3
72
26.3
73
28.2
74
60
10.8
62
14.1
64 1
17.6
69
j 19.3
99
21.6
72
23.3
73
25.4
7i
27.5
76
( 29.3
76
65
11.3
63
14.7
66
1 15.3
69
20.1
71
22.5
73
3A.3
7a
26.5
76
28.5
77
30.5
78
70
117
65
15.1
68
19-0
71
20.9
73
73.4
75
25.3
75
27-5
78
29.6
79
31.9
81
75
12.1
66
15-8
69
19.6
72
1 21.7
74
24.1
76
26.1
77
29.6
79
30.7
90
33.0
82
80
T?.5
6e
16.3
71
20.3
74
22.5
7e3
24.9
78
27.0
80
79.5
al
31.7
at
34.1
83
NOTE: Stated performance ct BASE PRESSURE.
PLEA5E REFER TO 'WARRANTY AND DiSCLAIMEV STATEMENT ON PAGE 16
�Pk4cn Irriga€ioa (up. 848 Aiumn Rd. 17oi1n WQ1lo, WA 9M2-2271 i153! id: 509,5253666 Fei: 509 M1907 r-mail ink@celmeimiga;ion.mm Web site: rwar�s><son(rrlpatiaamm

t �yy ,, 41 `l�F',L ` 1,1r' •,
y •h� �
• �. �,Sr;�' yin•, ;�4� • ,
. �.v,r i�y,,... r, . ° ,ar'l.. 4 �.�1'y fir Fv.rr�, `!�. ,•',�-.. ` F�•��"y,
. ,
' iLgs {•• !- .i - C ` C�7L(�"`'rtrj7Nl,t= ��� y,1.4S•'ih .
kill
_ � rr y I_t {. 'ter [ r' •! !'T{'.r Y'�!�`t r-.�;yM�7", ..
.t I ,,4 •,` �� rr Y'f'+ rA',�,�,f r �i,�t'n,' �� �: •' .. r ,$' 4' 1 r - � . '
�•�•' �'� ��'�'a�?+ ti � � ?��F �� I r�ry ':r •ter ,.. ar � L +- ' ` r '
• l ~} i.1:l+��34ti S r w! r �frd �.4 I r +��,,, -rt_
,� Lt'�t,!t,.r ' 1 d �' i�RJ �� Ia r ' � _ Y , y , ,L'• 1 `., ., Y , = 1.
•,ir; 3 f •,,y,},rW, i' , ti r + r,` r r y s `,
, "',Y� -f �(��+ F s Lr•-� + "tc rt'" l,�i ��YJ1��i'
n:vgRt r, 'V.r-r,` -'wy, r; �±r 'r, ' ti -;•)� , �^' ��y°11'"'
T t t,.tlg
f •�
. y
40
J

gz -3sl
Required Specifications For Animal Waste Management
1. Animal waste shall not reach surface waters of the state by runoff, drift; J
manmade conveyances, direct application, or direct discharge during,
operation or land application. Any discharge of waste that reaches surface
water is prohibited. -
2. There must be documentation in the design folder that the producer either
owns or has an agreement for use of adequate land on which to properly
apply the waste. If the producer does not own adequate land to properly
dispose of the waste, he/she shad provide evidence of an agreement with a
landowner, who is within a reasonable proximity, allowing him/her the use
of the land for waste application. It in the responsibility of the owner of the
waste production facility to secure an update of the Nutrient Management
Plan when there is a change in the operation, increase in the number of
animals, method of application, receiving crop type, or available land.
I Animal waste shall be applied to meet, but not exceed, the nitrogen needs
for realistic -crop yields based upon soil type, available moisture, historical
data, climatic conditions, and level of management, unless there are
regulations that restrict the rate of applications for other nutrients.
4. Animal waste shall be applied to land eroding less than5 tons per acre per
year. Waste may be applied to land eroding at more than 5 tons per acre per
year but less than 10 tons per acre per year provided grass filter strips are
installed where runoff leaves the field (see USDA, NRCS Field Office
Technical Guide Standard 393 - FUter Strips
5. Odors can be reduced by injecting the waste or by disking after waste
application. Waste should not be applied when there is danWr of drift from
the land application field.
6. When animal waste is to be applied on acres subject to floodin& waste will
be soil incorporated on conventionally tilled cropland. When waste is
applied to conservation tilled crops or grassland, the waste may be
broadcast provided the application does not occur during a season prone to
flooding (see "Weather and Climate in North Carolina" for guidance
-------------------------------------------------------_---------------------------------
764326 Database Verdou 2.0 Date Printed: 06-21-2002 spec;ific" Page 1 a
RECEIVED I DENP' ) "Q
AQU1��RPRfIT'Fr•TInN �F.CTIQN
PA 0 170

7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate
such that runoff does not occur offsite or to surface waters and in a method
which does not cause drift from the site during application. No ponding
should occur in order to control odor and flies.
8. Animal waste shall not be applied to saturated soils, during rainfall events,
or when the soil surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner
that the crop is not covered with waste to a depth that would inhibit growth.
The potential for salt damage from animal waste should also be considered.
10. Nutrients from waste shall not be applied in fall or winter for spring planted
crops on soils with a high potential for leaching. Waste/nutrient loading
rates on these soils should be held to a minimum and a suitable winter cover
crop planted to take up released nutrients. Waste shall not be applied more.
than 30 days prior to planting of the crop or forages brealdng dormancy.
11. Any new swine facility sited on or after October. 1. 1995 shall comply with
the following: The outer perimeter of the land area onto which waste is
applied from a lagDon that is a component of a swine farm shall be at least
50 feet from any residential property boundary and canal Animal waste,
other than swine waste from facilities sited on or after October 1,1995, shall
not be applied closer that 25 feet to perennial waters.
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other
than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and public
right-of-ways.
15. Animal waste shall not be discharged into surface waters, dramageways, or
wetlands by a discharge or by over -spraying. Animal waste may be applied
to prior converted cropland provided the fields have been approved as a
land application site by a "technical specialist". Animal waste shall not be
applied on grassed waterways that discharge directly into water courses,
and on other grassed waterways, waste shall be applied at agronomic rates
in a manner that causes no runoff or drift from the site.
----------------------------------------------------------------- ---
764326 Database Version 2.0 Date Printed: 06-21-2002 Specification Page 2 a

16. Domestic and indudrial waste from washdown fad, showeas, tins,
sinks, etc, shall not be discharged mto the anal waste ma ement
17. A protective corer of appropriateveg#stion will be established GRIM
disturbed areas (lagoon berms pipe runs, etc). Areas shall
be feed, as necessary, to protect the v en. Vegeadon such as li=%
- shrubs, and other woody species, etG, are limited to areas where considered
aPLagwo area should be kept mowed and ale. Berm
and structures should be inspected Orly for evidence of won,-.
or. discharge.
I& 1f animal prodaction at the faaft is to be suspended or tennuabed, the
owner is responsile for obtabft and im a "closure plan" which.
will 'eliminate the P bil H.of an Mq
rL% Porn, ami Win:
19. - Waste hand PiPft pumps, redetc., be inspected an
a regular basis to prevent breakdowns,leaks, and spills. A regular
mabdwance dwddbt should be kept on site.
20. Aniigmal waste can be used in a rotation that includes voles and other
MPS for direct h W=n ea ptinn. However, if animal waste ls and on
crops for direct h M=M aoptioa, rt should only be appKed Pn!�-P
with no farther applications of animal waste during the crop season.
ZL Wly viole markm sbaB be iasbW to mark the top and bgUom
elevations of the ' F m porary storage (pmnph g volume) of all waste
fteahnent lagoons Pumping shall. be mated to MhMW the ftmd level
between the makka& A marker win be required to mark the ma®mum
storagevolume forwaste storage ponds.
- - - - ----------------------------------------. - - - - - - - - - - - - - - - - - - - -
76+1326 Die V�sdoa 2.0 DE6e Fn� 06-21 2002 3 a

22. Waste stall be tested within 60 days of a0zation and soil shall be tested at
least annually at crop sites where waste products are applied. Ndirogen
shag be the rate-deftnnWft nutrie4 unless other re rictions require
waste to be applied based on other nutrients, n=Wwg in a lower application
rate than a nitrogm based rate. Zinc aid copper levels m the sow shall be
monitored and aftamative crop sites shad be used when these metals
approach excessive ievehL pH shaR be adjusted and maintained for
optimum crop production Sol and waste analysis records shaR W kept for
a minim® of five years. Poultry dry wade application records shaII be
maintained for a minimum of three yeam Waste application. records for all
other waste shaR be maintained for a mmMM of five years.
23. Dead animals wdl be disposed of in a manner that meets North Carolina
regulations.
-----------------------------:-----------------------_---:------�---------s ----
764326 Dafabe Verdam 2.0 Daft P40* 06-21• 4 a

Crop Notes
The 5ollawing crop note applies to field(s): ZONE I
Ben dagram Coastal Plain, Mmieral Soil, Poorly Drained to Sa nwe bat Poorly Drained.
Adaptatiom- Five artificial drainage MUST be in phwe to adimm Realistic Yidd Expecadions
provided fear these soils -
Ea the Coastal Plain, hybrid bMMLIULLndagrass sprigs can be planted Mar. 1 to Mar. 31. Cover sprigs I" to 3"
deep (1.5" optimnal). Sprigs should be pktbd quicW after and not atiowed.to dry in sum and wig
For Coastal and TAM 78 plad at least 10 bloc in 3' rows, spaced 2' to 3' in the row. GenmmBy a raft of
30 bu/sac is dory to produce.full groundcover in one or two yeas ender good growing oonditiwos.
Tdion 44 spteeds slowly, so use at lest 40 ba/ac in 1.5' to 2' rows spaced 1' to 1-5' in row. For
broadw.st/dsivod- sprigs use about 60 bo/ac. Sort test for the amounts of lime, phosphorus, po'tassrum
and to apply preplamt and for amoral woe. Apply 60 to 100 Ache N in the
esbbhdmxW year in split applications in April and July- Far wed stands apply 180 to 240-%Mc N
annually in split applications, usually in April and Mawmg the fast and second bay cuts. Red= N rates
by 25% for graziu& R ar to NCSU Tecibm wal Bunctia 305 Pmd mdm and uffmfim of Pasmm and
Farms in North Carolina Suror comet your nmiaml agrowaarist or cdoxim agent for
assidanw.
The f & wing Cmp now to &Way ZONE 2
Bermnda�grass Coastal Plain, blmmal Sail, Moderately Well Drab=&
nm wd.bpoma.
In fire Coastal Plain, hybrid beang = sprigs cam be planted Mar. 1 to Mar. 3 I. Cover sprigs I"to 3"
deep (1.5" optimal). Sprigs should be planted gWddy alien and not SHOWed to dry in Sara and wind.
For Coastal and T-x&m 78 plant at least 10 bu/ac in 3' rows, spaced 2' to 3' in the row. Generally a rate of
30 bloc is satisfitcomy to produce fill grounds over in one or two years Hader good grawving conditions.
I'Am 44 spreads skmvly, so use at least 40 bu/ac in I Y to 2' rows spaced V to 1.5' in raw. For -
broadc sprigs rase about 60 butk. Soil teat for the amounts of lime, phaRbome, mum
endinom to apply pieplamt and for annual . Apply 60 to 100 lb/ac N in the
estabiishmmt year in split apples in April and July. For: establisIbed stands apply 180 to 240 Ww N
amorally in split applicaticins, usually in Aptil and following the first and sw d hay cats. Rehm N raw
by 25% Eor gmzin& Refer to NCSU Technical Ekdk Zian 305 Pry and UtMZ36 n Of Pastures and
Farms in Naath Carolina foror consult yoar regional agr or age for
assistance.
-----------------------------------------------------------------------------P ---- -----
764326 Database Versi� 2.0 name Priatc& 06-21-2002 Note Page 1 of

1be Mowivg cep now apes to field(s)_ ZONE i
Small G m m: CP, Mitec ml Sod, low -leachable
In the Coastal Plam , oats and barley W=W be planted fiom October 154)dobw 30; and rye fmm October
15 Novembcr 20.- For badcy, plain t 22 seedldr l ww fiat and mmm the seedmg rate by 5% for cab
weak swft is delayed beyond the apti timm See the seeding rates uble ft apfimblc sewing rate
modifica*w in the eaureent NCSU "SmuM Grain Prodwaion Gads"- Also, a the initial sanding rye
by at hag 10% when phm mg nD4U Oats should be plamod at 2 bushels/a me and rya: at 1-1 U2
bmdmfacm Plant all these small grains at 1-1 Ur deep- Adequate depth caul is essential Review the
NCSU Official, Variety "green body and m# mnafi a' fiam privew 1 to smhxt a bigb yie
variety with the d: wbsd needed fear you area amd oan Genes. Apply no m m than 30 lbs/ame N at
a phudiB& Phaspbomm and po sh reoomrma5ndod by a snail test can also be applied at this time- The
remaWW N should be applied during the of Febm wy-bbrdc
The f kmmg c mp note applies to field(sr ZONE 2
Sm U Cain:. CP, bfimd Sod, medium lea doble
In the Coastal Plain, oats and barley should be plarmod fiom October 15 Oc,tober 30; and rye fioam► October
15-Navember 20. For barb , phad 22 sw&drffl raw faxat and inmease the seeding rate by 5% fiar tech
week seeding is delayed beyond the of " time. See the see&* ntcs table for applicable seeding raft
in the arrre-nt NCSU "SumM Grain Proms Guide". Also, mocase the idtial seodiag rase
by at least 10%wmn plauft =401- Oats should be pbowd at 2 bmdwWa= and rye at 1-1 1R
busbcWirr. Plant all these sm W grains at 1-1 1R" deep- Adegmft depth cam' r I is esscofi3L Review the:
NCSU Official Variety "gmm boor and i on fiaar private eoupmies to select a high ykd&g
variety with the buistics needed for you am and . Apply no ma re than 30 Ibslacm N at
ph°nfim- Phoghum and 1?Amh b9 a sod test can also be applied at this time. 'Ibe
remaicuug N should be applied dicing the mou ffis of F
-------------------------
760M Database Versim 10 Date Printed: 06-21 2002 Crop Note Page 2 of

WASTE U ELIZATION PLAN AMENDMENT
This amendment is included to address the wastewater that may need to be pumped, for
maintenance purpose, from the abandoned lagoon.
Lgoon # _ Surface Area
Rainfall in excess of evaporation during 12 month period in Sampson County = 11.23
inches (0.94. foot)(From Rainfall -Evaporation Chart for Area 3).
Volume of Rainfall to be Pumped From Abandoned Lagoon
1 = 182,982.65 gallons
PAN fivm Waste Analysis Report for Abandoned Lagoon = 0.15 N/1000 gallons_
Total PAN from the abandoned lagoon that may need to be applied per year for
maintenance = 27.4 Ibs N.
The PAN deficit from the existing waste utilization plan is (-721 lbs N). The new deficit
is (-693.6 ibs N). Therefore, there is adequate land included in the existing waste
utilization plan to treat the wastewater pumped, for maintenance, from the abandoned
lagoon.
44r
5M CAL SPE IALIST
1 : D
DATE
7-g- °-z-
DATE
RECEIVED I DENR I DWO
AQiltFr'q-Aan-rFrT7()N .SFr,TroN
APR 0 1700R

The Available Waste Storage Capacity table Provides aar estimate of the mirrber of days of stmage
capacity available at the end of each month of the plan. Available storage capacity is calailated as the
design storage capacity m days mime the number of days of net storage volume aa,unuiata i The start
date is a vahte entered by the user and is defined as the date prim to applying mitrieats to the ft st crop in
the plan at which starage volume m the lagow or holding pond is equal to aero.
Available storage capacity should be greater than or equal to zero and less than or equal to the design
storage capacity of the facilityif the available storage capacity is greater dmthe design storage capacity,
this indicates that the plan calls for the application of mitnents dw have not yet ac rnulated. If available
storage capacity is negative, the estimated volume of ao milated waste exceeds the design storage vohune
of the strwhaec Either of these sittum ms indicates that the planned application mterval.m the waste
u fli- a ion plan is inconsis ant with the strudwVs temporary storage capacity.
Available Waste Storage Capacity
Scarce Name
Swine F -W non Liquid
Design Sto C achy (Days)
Start Dais
9130
180
Plan Year
Month
Available Storege Capacity (Days)
1
1
107
1
2
93
1
3
147
1
4
190
1
5
1ti0
1
6
180
1
7
1ti0
1
8
1ti0
1
9
190
1
10
159
1
11
139
1
12
113
* Available Storage Capacity is calculated as of the end of each month.
----------------------- --------------------------------------------------------- - ---
764326 Database Version 2.0 Date Printed_ 06-21 2002 Capacity Page 1 of 1

The following Lagoon Sludge Nibrogm iJtrlizatiian table provides an estimate of the mamba of acres nwded.for
sludge enilization for the indicated acam nulation period These estirnates are based on average nitrogen
corrAxitrations for each source, the number of animals in the facility and the plant available nitrogal application rates
shown in the second caiurra
Lagoon nudge contains nutrients and orrgarlic matter remaining after treatnu mt and application of the effiumt- At
dean out, this material mist be utilized for crop production and applied at agrars conic. rates. In most cases, the
priority nutrient is nitrogen but other nutne ns mcluding phosphorous, copper and zinc can also be limiting Since
nutrient levels are gaierally vary highs applicatiioan of sludge must be arefilnly applied
Sites must first be evaluded for their suitability for sludge application. Ideally, effluent spray fields should not be
used for sludge application. If this is not passible, care should be taken not to load effluent application fields with
high amounts of capper and zmc so that additional effluent camot be applied. On sites vulnerable to surface vMw
moving to streams and lances, phosphorous is a concern Sods containing vay high phosphorous levels may also be a
Lagoon Sludge Nitrogen Utilization Table
Crop
Maximum
PA-N Rate
vac
Maximum Sludge
Application Rate
1000 gal/ac
Minimum Acres
5 Years Aoamaulation
Minimum Acres
10 Years Aommulation
Minimum Acres
15 Years Accumulation
Swine Farrowing W=Wing Lagoon Sludge - Standard
Com 120 ba
150
13.16
14.82
29.63
44.45
Hay 6 ton RYY-
300
26.32
7.41
14.92
22 ZZ
Soybean 40 bu
160
14.04
13.89
27.78
41.67
---------------------------------------------------------_-------------------------__ -----_ _
764326 Database version 2.0 Date Printed: 06--21-2002 Sludge Page 1 of 1

The Irrigation Applicatim Factors fur each field in this plan are shown m the fdilawing table InWahm
rate varies with sails. If applying vsr�e nutrients dumt& an irrigation systems you mast apply at a rate
that will not result m runoff This table provides the unidu urn application rate per hour that may be
applied to each field selected to receive wastewater. It also lists the nuKimum application anx mt that
each field may receive in any one application evem
Irrigation Application Factors
Tract
14491PONE2
Flew
Soo Saics
ApphCalim Raft
Appficafm Amouil
(Mch-)
4481
ZONE 1
Goltdxro
0.50
096
At6tyvttHc
0.60
0.72
---------------------------.----_------------------------------------------------------- -- --
764326 Databe.9e Version 2-0 Doe minted 06-21 2002 IAF Page I of I

Waste Utilization Table
Year 1
Tract
Field
Source
I.D.
Soil Series
Total
Acre
Use.
Acres
Crop
RYE
RYE
Unit
Applic.
Period
Nitrogen
PA
Nutrient'
R 'd
Comm.
Pert.
Nutrient
Applied
Res.
Appilo.
Method
Manure
PA
Nutrient
Aelied
Liquid
Manure
Applied
acre
Solid
Manure
Applied
acre
Liquid
Mama
Applied
Field
Solid
Manure
Applied
Field
(Ibs/A)
N
(lbslA)
N
(lbslA)
N
lbarA
N
1000
pi/A
I tons
1000 gals
tons
4481
ZONE
S9
0oldeboro
3.5
3.5
Small Orain Overseed
1.0
Tom
10/1-3/31
50
0
0
brig
1 30
14.9
0.0
52.1
0.0
4481
ZONE
p
ldsbtT'5-
3.5
3.5
Hybrid Bennudagrass
Ha
6.5
Tons
13/14/30
�(
0
0
Irrig.
296
176.4
0.0
617.3
0.0
4481
ZONE
S9
Autryville
7.0
7.
Smell Chain Overseed
1.0
Tom
10/1-3131
50
0
0
Irrig,
50
29.8
0.0
20&S
0.0
4481
ZONE
89
Autryvilie
7.0
7.0
Hybrid Bermudagrass
Ha
5.4
Tom
3/1-9130
264
0
0
brig.
264
157.3
0.0
1,101.I
0.0
�---
Lagoon Liquids
Total Applied, 1000 gallons
1,979
Total Produced, 1000 gallons
1,602
Balance, 1000 gallons
-378
Manure Solids
Total Applied, toes
0
Total Produced, tom
0
Balance, tons
0
Notes: 1. In the tract column, symbol - means leased, otherwise, owned. 2. Symbol • means user erdered data.
TAM 974 Fr'M 04-4 �'o� ca/mo/-b SO' 44ove. �,41e- wW de Jae-ti 16 V
�lOu�,�-S' cs� nr'"�� t:►•. sae. cr��e. .CD �a.`�' �-;�rt� Ccr,.1 �2. N.s e1'r^a3� ar ayt.�. Soi � � fog..
1p� ;6 PAN ►j y �- if ` -4Q ?A �= 4 o� ,rm,-c e- PJ .� ,lr 9 � %r n I�a. '�c e. e , � r r /v its. ► c. �r t w r ?__
�MGd.fl. i" ✓'yil«-7" 1 ""'�J G�awba.. �
-------------------------------------------------------------------------------------------------------- ---
764326 Database Version 2.0 Date Printed: 06-21-2002 WUT Page 2 of 2

Memo
TO: AQUIFER PROTECTION; FAYETTEVILLE REGIONAL OFFICE
From Complaint: Ms. Jo Strickland (910-590- 855)
Re: Land application of sludge
Enclosed with this memo is the information that was provided during a phone call on 2 March 2007
from Ms. Jo Strickland concerning the land application of sludge in the Garland, Sampson County NC
area. The following information and items are enclosed:
1. According to Ms. Strickland, sludge is being land applied to land owned by G.W. Norris and
Anthony Johnson (mayor of Garland) approx. 1 mile north of town off of Highway 701. The sludge
application started on Weds, 28 Feb. 2007 and continued into Thursday 1 March. Sludge land
applied on 1 March was not incorporated prior to the heavy rains that hit the Sampson County area
early in the morning of 2 March. Concerns were that sludge could have washed into ditches
adjacent to the application fields that lead to area surface waters. Ms. Strickland was not
complaining or lodging a complaint at this time relating to odor;
2. Ms. Strickland stated that Garland was land applying sludge from the town wastewater treatment
plant (Ms. Strickland thought that the sludge was from the town of Garland, due to the fact she
witnessed Ricky Brown, Town of Garland wastewater treatment plant operator at the site). Upon
calling Mr. Brown at 12:56pm on 2 March 2007 and asking about the land application of sludge in
the area, Mr. Brown stated that Garland wasn't land applying sludge. At this time Mr. Brown called
the mayor of Garland, Mr. Anthony Johnson, to inquire about the land application activity. Mr.
Johnson informed Brown that the sludge was in fact from a hog lagoon and that the sludge came
from the Sammy Home farm (AWS 82-381). According to Johnson, Mr. Dan Bailey could be
contacted for information concerning the land application event on the Norris and Johnson land;
3. Enclosed with this memo are ortho-photos from the Sampson County GIS website that show the
application property with Hwy 701 bisecting the farm land of GW Norris and the Johnson property
adjacent to the Norris land. The ortho-photos do not show ditches bisecting the properties in
question. Hwy 701 crosses the Black River approx. 1 — 2 miles north of the application fields.
4. Town of Garland contacts: Ricky Brawn or Kristy Kersey at 910-529-4141.

Sampson County Map Viewer Page 1 of 1
�,y+"er cityrsft:lir:tctir;�lc�,c;�tti�
� # VM � of � La. rn 1 i vil x,m In, tf! y� ito SPARCH RESULTS LAYERS UOINO PRINT
- :'��� � I� � / I,U1 oog : iv*a1vra �-IrPE44 Zao�n In Lc^ � : �h 7,. �,� : c h . � r ;
Parcels: Selected Records
[1 to of 1]
��cxrr.�srun�irir�
Record: 44197
•m
AREA
1399752.64518
PERIMETER
5180.26897
ALLPARCEL
44198
N4
PRODNO
1388000107
PIN
1388416447
CALC ACRES
90.921
COUNTYPID
16011496601
FTR_CODE
PARCEL
SUBNO
0
ZONING
ID
40047.00000
OWNER
NORRIS, GEORGE W
NORRIS, SANDY B
�-OWNERI
PO BOX 552;
Map Scale: t in = 1346 ft W, 0 1 1346 ft
littp,//gis.sampsonnc.com/Defauit.aspx 3/2/2007

Sampson County Map Viewer
. ftl1/W'o On City or crolon
;j l!♦ u♦ �+' / �? lu SEARCH RESULTS ' LAYERS /FOEND ' PRINT
min : Xomm Vu, ZaomF II Pnaws X loyd P r • 10/Long 1 M ,vrc
Parcels: Selected Records
[1 to 1 of 11
-si
U Record: 44054
k., '
AREA
4098968.24177
PERIMETER
11573.92027
ALLPARCEL_
44055
N4
PRODNO
1388000107
PIN
1388416447
CALC ACRES
90,921
COUNTYPID
16011496601
FTR CODE
PARCEL
SUBNO
0
ZONING
L ID
411047,00000
OWNER
NORRIS, GEORGE W
NORRIS, SANDY B
OWNERI
�m
PO BOX 552
Map Scale: 1 In = 1346 ft &Is 0 0 1346 ft
http://gis.sampsonnc.com/Default.aspx
3/2/2007

Sampson County Map Viewer
Page 1 of 1
Q
ac.c..v�ln. X��'n`+�E: rorsrilali ar+�-ut- %a. vTilap� I.yn 14+f i✓trlon�;, .F,6au ri i'IfNor',Irl, :�i� f+aeri.rli iuyn
Map Scale: 1 In = 1346 _ 6EM 0 1346 ft
SFARCSEARCHR.rrSUtfiS CATERS 1:GOF04Q PRfNt_
Parcels: Selected Records
(1 to 1 of 11
E) 0 Record: 44297 OYU. m
AREA 2339309.85938
PERIMETER 6237.70667
I ALLPARCEL 44298
N4
PRODNO
1388000046
PIN
1388860558
CALC ACRES
0
COUNTYPID
16074912104
FTfi_CODE
PARCEL
SUBNO
0
ZONING
ID 41202.00000
OWNER JOHNSON, MARYANN N
JOHNSON, ANTHONY
9WNinR1 161 N WH17E LAKE
http://gis.sainpsonnc.com/Default.aspx 3/2/2007

Sampson County Map Viewer Page I of I
www.cityolclintonnt.
Z.;�'00 Z...N.11 P, L..g; HYP.,W 1 S..H 1 tAYUS LIOWD PINNIr
Parcels: Selected Records
[I to 8 of 8]
m"r-M.&MMIME
vm=�
(0 b Record: 20618 Lai.j- �j
AREA 20181.11719
(i) 0 Record: 42851 (1
AREA 9173.88587
E@ b Record:
1
42852
Record: 42860
AREA
1792349.67393
M Q Record:42940
GM
AREA
880205.66016
M 0 Record: 43036
AREA
1292427.06635
http://gis.sampsonnc.com/Default.aspx 3/2/2007

Marshall Horne
Marshall Horne Farm
2595 Lamb Rd
Garland NC 28441
Dear Marshall Horne:
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, f . E., Director
Division of Water Quality
October 1, 2004
OCT 15 2034
QENR - FAYE7tEVILLE REGIOML OFRCE
Subject: Certificate of Coverage No. AWS820381
Marshall Horne Farm
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
On June H , 2004, the North Carolina Division of Water Quality (Division) issued a revised State General
Permit for swine facilities. The General Permit was issued in accordance with the directive of Senate Bill
733 (Session Law 2003-28).
In accordance with your application received on February 20, 2003 and in accordance with the directive
of Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to
Marshall Horne, authorizing the operation of the subject animal waste collection, treatment, storage and
land application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AWS820381 which expires October 1, 2004.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Marshall Horne Farm, located in Sampson County, with an animal capacity of
no greater than an annual average of 500 Farrow to Wean swine and the application to land as specified
in the facility's Certified Animal Waste Management Plan (CAWMP). if this is a Farrow to Wean or
Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary,
they may be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a
rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Since this is a revised State
General Permit, it contains new requirements in addition to most of the conditions contained in the
previous State General Permit. Enclosed for your convenience is a package containing the new and
revised forms used for record keeping and reporting. Please pay careful attention to the record keeping
and monitoring conditions in this permit.
Aquifer Protection Section - Animal Feeding Operations Unit
1636 Mail Service Center, Raleigh, North Carolina 27699-1638
Phone: [phone] FAX: [phone] / Internet: h2o.enr.state.nc.us
An Equal Opportunity/Affirmative Action Employer - 50% Recycled110% Post Consumer Paper
NorthCarolina
Aaturally

If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 2H .0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100 foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any.wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a- county covered by our Fayetteville Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Duane Leith at [phone].
Sincerely,
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG i 00000)
cc: (Certificate of Coverage only for all cc's)
Fayetteville Regional Office, Aquifer Protection Section
Sampson County Health Department
Sampson County Soil and Water Conservation District
Permit File AWS820381
APS Central Files

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P. E., Director
Division of Water Quality
May 1, 2003
Marshall Home
Marshall Horne Farm
2595 Lamb Rd
Garland NC 28441
Subject: Certificate of Coverage No. AWS820381
Marshall Horne Farm
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
Dear Marshall Horne:
On April 28, 2003, the North Carolina General Assembly ratified Senate Bill 733 which directs the
Division of Water Quality (Division) to extend the expiration date of the Swine Waste Operation General
Permit AWG100000. Therefore, the General Permit has been re -issued by the Division to extend the
expiration date to October 1, 2004. During the period of this extension the Division will be working with
all interested parties on the development of a new version of the Non -Discharge General Permit.
In accordance with your application received on February 20, 2003 and in accordance with the directive
of Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to
Marshall Horne, authorizing the operation of the subject animal waste collection, treatment, storage and
land application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AWS820381 which expired on April 30, 2003.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Marshall Horne Farm, located in Sampson County, with an animal capacity of
no greater than an annual average of 500 Farrow to Wean swine and the application to land as specified
in the facility's Certified Animal Waste Management Plan (CAWMP). if this is a Farrow to Wean or
Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary,
they may be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a
rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until October 1, 2004. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
_A -A r.a._1'% A F f`Ilr *_
laws, 1aics,LLQlll M1LL111atA%Aa 11V\.QI, aLQL%,, al1LL 11.LLVIal), 1101 6a VVl nfo
GL UVt+ Ly vra�..ru «v
under this permit convey any property rights in either real or personal property.
NNMENR
Non -Discharge Permitting Unit
1617 Mail Service Center, Raleigh, NC 27699-1617
Customer Service Center
An Equal Opportunity Action Employer
Internet http:/Ri2o.enr.state.nc.us/ndpu
Telephone [phone] Fax [phone]
Telephone [phone]
50% recycled/10% post -consumer paper

Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per NRCS standards a 100 foot separation shall be maintained between water supply wells and any
lagoon or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such. a request is made within 30 days, this COC shall be final and binding.
This facility is located in a -county covered by our Fayetteville Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact J R Joshi at [phone] ext. 363.
Sincerely,
Zdel_
v
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
Fayetteville Regional Office, Water Quality Section
Sampson County Health Department
Sampson County Soil and Water Conservation District
Permit File AWS820381
NDPU Files

Wettable Acres Determination Certification
Name of Facility:
AOdif.4LL
Facility Number: g2 - 38i
Ow-ner(s) Name:
HK LL
A a/E
Phone No: 910-SZ 9 - g zA'1
Mailing Address:
ZSys (Arwb_
144,E -
IAr-A , /✓ C Z 84 Y 1
By signing this form, the facility owner and Technical Specialist acknowledge the completion of the
Wettable Acres Determination. All necessary Wettable Acre Determination Field Data Sheets and
calculations were completed to conduct a Wettable Acre Determination. The facility's Waste
Utilization Plan has been amended as necessary to reflect actual wetted acreage. A copy of all
worksheets, calculations, and other Wettable Acres Determination documents, along with the
applicable Waste Utilization Plan and Wettable Acre Determination Certification will be filed with
the local Soil and Water Conservation District. A copy will also be kept on site with the Certified
Animal Waste Management Plan. Any future modifications must be approved by a technical
specialist and filed with the Soil and Water Conservation District prior to implementation. If any
modifications to the existing irrigation system or any new irrigation equipment was required to
adequately address the waste management needs of this facility. an Irrigation Specialist or
Professional Engineer has certified the design and installation below.
Owner Name: JAe&,O t It Pn*JG-
Owner Signature: Date: m�
Technical Specialist Name: FvT`
Technical Specialist Signature: Date:-7- '7- OZ
If assisted by an Irrigation Specialist or Professional Engineer please read and sign below:
Animal waste application equipment has been designed or modified to apply waste as necessary to
accommodate the waste management plan aid according to N'RCS Standards. Animal waste
application equipment has been installed according to MRCS Standards and is ready for use.
Irrigation Specialist/PE Name:
Irrigation Specialist./PE Signature:
Submit this form to:
Attn: Sonya Avant
Non -Discharge Compliance Unit
Division of Water Quality
1617 Mail Service Center
WADC — 7/99
Date:
n
FES 2 0 21IX2 1

Irrigated Acreage Determination Procedures
for Wastewater Application Equipment
STATIONARY SPRINKLER SYSTEM
FIELD DATA WORKSHEET *
I. Sprinkler make and model number 6epj wt� r) 02-5, RD
5
2. Sprinkler nozzle size-W2 0 NOZ to mm _ _ _ [inch]
3. Lateral spacing Bo [feet] by sprinkler spacing along lateral O [feet]
?. Operating pressure at the sprinkler 3S [psi]
S. Sprinkler wetted diameter 111 ffeet], measured or determined from chart.
a
6. Number of sprinklers operating at one time I V
7.
Total number of sprinklers or sprinkler locations in the system
Exterior sprinklers: D full circle 4
part circle
Interior sprinklers: _ .J�' y
full circle
Sprinkler locations permanently marked: Vol' yes
no
S.
Supply line Permanent pipe
Portable pipe
"9.
Lateral line size [inch;. If there is more than one size, indicate the size and
approximate length of each. Can be done on the map.
"10.
Lateral line length
[feet]. (Longest lateral)
"11.
Supply line size _ [inch]- If there is more than one size, indicate the size and
approximate length of each. Can be done on the map.
"12.
Supply line length [feet).
%laximurr: pumping distance.
' i]i.
rump make and model number
"1-4.
Pump capacity _
_ (gpml
"is-
Engine make and model number
or
"16.
Electric motor ;:orsepower and rpm [hp]
[rpm]
Note: It is strongly recommended that you field measure the sprinkler wetted diameter. You should do this on the
longest lateral about half -way down the lateral.
' Locate each sprinkler or sprinkler location on the map. Indicate whether it is full circle or part circle. Show the
location of the supply line. Irrigated acres are determined by 'lateral line, by zone, or by field.
Optional data, furnish where possible
"' Information furnishAv /
andlor
Signature of owner or facility representative Si navare of technical sp ciahst
f1,> �A�EF-raa7- 1 FEB 2
Printed name of owner or facility representative Printed name of technical specWist
Date ;Date 1P — 20 — 07—
"" Only the person or people collecting the data should sign the Field Data Worksheet.

Irrigated Acreage Determination Procedures
for Wastewater Application Equipment
STATIONARY SPRINKLER /GUN SYSTEM
WETTABLE ACRE COMPUTATIONAL WORKSHEET
1_ farm number (identification) A&M44-"F Field number (identification) _
2. Irrigation system designation Existing irrigation system
New/expanded irrigation system
3. Number of stationary sprinklers 5� # Interior sprinklers 3 Z' # Exterior sprinklers
4. Wetted diameter [feet] from Field Data Worksheet
5. Spacing So Sprinkler spacing along lateral [feet]
so Sprinkler sparing as a percentage of wetted diameter
5. Sprinkler pattern Multiple laterals Single lateral
Excessively spaced sprinklers
7. Read the irrigated area per sprinkler for the given wetted diameter from the appropriate table and
column based on pattern, spacing, and sprinkler location.
O• 133 acres per interior sprinkler from
0.133 _Acres per exterior sprinkler from
Table t Column V
Table to Column v
8. Multiply the tabulated irrigated acreage value per sprinkler by :he number of sprinklers of each
category in the field. Add all of these. The sum is the total irrigated acreage for the field.
�113 3 (a) :acres per interior sprinkler X (01 # Sprinklers — B• «� Acres
a' 133 (b) .acres per exterior sprinkler X /8 # Sprinklers = 2. 39Y Acres
/0. S#7Total wettable acres for field (Snm: sa /tiature
Wettable Acre Computational Worksheet completed bv:
technicai sp 'alist

Nutrient Management Plan For Animal Waste Utilization
This plan has been prepared for:
Marshall Horne SOD Sow Farm
Marshall Horne
2595 Lamb Road
Garlanc4 NC 28441
910-529-9281
06-21-2002
This plan has been developed by:
Matthew Barefoot
,Sampson SWCD
84 County Complex Road
Clinton, NC 28328
;91U-5,)2-7963 Ext. 3
D&eloper Si
Type of Plan: Nitrogen Only with Manure Only
Owner/Manager/Producer Agreement
I (we) understand and agree to the specifications and the operation and maintenance
procedures established in this nutrient management plan which includes an animal waste
utilization plan for the farm named above. I have read and understand the Required
Specifications concerning animal waste management that are included with this plan.
FIA
Signature (owner)
Signature (manager or producer)
-mom
Date
Date
This plan meets the minimum standards and specifications of the U.S. Department of
Agriculture - Natural Resources Conservation Service or the standard of practices adopted
by the Soil and Water Conservatign Commission.
Plan Approved By:
T hnical Specialist Signature Date (�i L3 E : SCGT!OFJ
FEB 2 0 2003
- 7-64326---------- Database Version 2.0 Date Printed: 06-21-2002 ITT!NG

Nutrients applied in accordance with this plan will be supplied from the
Mowing source(s):
Commercial Fertilizer is not included in this plan.
S9
Swig l+airowmg-Weanling Lagoon Liquid waste generated 1,601,500
galslyear by a 500 animal Swine Farrowing-Weanling Lagoon Liquid
operation. This production facility has waste storage capacities of
approximately 180 days.
Estimated Pounds of Plant Available Nitrogen Generated per Year
Broadcast
2473
Incorporated
4247
Injected
4677
Irrigated
2688
Actual PAN Applied
(Pounds)
Actual Volume Applied
(Gallons)
Volume Surplus/Deficit
(Gallons)
Year 1
3,409.00
1,979,027
-377,527
------------------------------ ----- -----------------
---------------------------------
Nate: In source m. S means standard Source. CF means user defined source.
764326 Database Version 2.0 Date Printed: 06-21-2002 Source Page l of i

Waste Utilization Table
The Waste Utilization table shown on the following page(s) summarizes the waste utilization plan for this operation. This plan provides an estimate of the number of
acres of cropland needed to use the nutrients bang produced. The plan requires consideration of the realistic yields of the crops to be grown, their nutrient
requirements, and proper timing of applications to maximize nutrient uptake
This table provides an estimate of the amount of nitrogen required by the crop bang grown and an estimate of the nitrogen amount being supplied by manure or other
by-products, commercial fertilizer and residual from previous crops. An estimate of the quantity of solid and liquid waste that will be applied on each field in order to
supply the indicated quantity of nitrogen from each source is also included.
A balance of the total manure produced and the total manure applied is included in the table to ensure that the plan adequately provides for the utilization of the
manure generated by the operation. Animal operations that generate liquid waste and utilize waste storage facilities (lagoons or holding ponds) may apply more or
less waste in any given year than is annually generated by the facility. In order to determine whether the plan adequately utilizes the waste produced by the facility,
the storage capacity table included in this plan should be reviewed to ensure that the design capacity of the storage facility is not exceeded during the planning period
Depending on the requirements of the crop and the nutrient content of the waste, some nutrients will likely be over or under applied if animal waste is being utilized.
Waste should be analyzed before each application cycle and annual soil tests are required if animal waste is being applied Soil tests should be used to balance the
nutrient application amounts with the realistic yields of the crop to be grown. Nutrient management plans may require that the application of animal waste be limited
so as to prevent over application of phosphorous when excessive levels of this nutrient are detected in a field
764326 Database Version 2.0 Date Printed: 06-21-2002 WUT Page 1 of 2

Waste Utilization Table
Year 1
Tract
Field
Source
I.D.
Soil Series
Total
Acre
Use.
Acres
Crop
RYE
RYE
Unit
Applic.
period
Nitrogen
PA
Nutrient
Req'd
Comm.
Fort.
Nutrient
Applied
Res.
Applic.
Method
Manure
PA
Nutrient
Applied
Liquid
Manure
Applied
(acre)
Solid
Manure
Applied
(acre)
Liquid
Manure
Applied
(Field)
Solid
Manure
Applied
(Field)
(IWA)
N
(lbs/A)
N
(IWA)
N
lbs/A
N
1000
gal/A
tan
1000 gets
tons
E
S
Ooldsboro
3.5
3.5
Small ChainOverseed
1.0
rons
10/1-3r31
50
0
0
brig.
50
14.9
0.0
52A
0,0
Z443911ZONE
NE
S9
lddxwo
3.5
3.
Hybrid &mwdagrass
Ha
6.5
ores
311-9f.10
296
0
0
brig.
296
176.4
0,0
617.3
0.0
NE
S9
ills
7.0
7.
Small Orain Overseed
1.0
rona
toll-3m
30
0
0
Inig.
30
29.0
0.0
209.5
0.0
S9
ilia
7A
7.o
IlybridHermudagrass
Hay
3.4
Tom
311-9130
264
0
01nig.
264
157.3
0.0
1,101.1
0.0
Lagoon Ligtdds
Total Applied, 1000 gallons
11979
Total Produced, Uff gallons
1,602
Balance, 1000 gallons
•379
Manure Solids
Total Applied, tans
0
Total Produced, tome
Balance, tons
0
Notes: 1. In the tract eahtmn, symbol — meets leased, oll—in. owned 2. Symbol • means user entered data.
-- -- - -- - - -- - - - --- -•-- -- -- - - ---- --- --- ------ - - - - -- ----------------------------- ------- - - - - --------- ---- ----------- - - - - -- -----
764326 Database Version 2.0 Date Printed: 06-21-2002 WiJT Page 2 of 2

The Irrigation Application Factors for each field in this plan are shown in the following table. Infiltratian
rate varies with soils. if applyung waste nutrients through an irrigation systems you unist apply at a rate
that will not result in runoff. This table provides the maxinum applications rate per Hour filet may be
applied to each field selected to receive wastewater. It also lists the maximum application armunt that
each field nay receive in any one application event
Irrigation Application Factors
Tract
Field
soil series
AppH a6an Rate
(inclxalh 0
Applicatim Amount
(1ches)
4481
ZONE t
Cold,lwro
0.54
0.96
4481
ZONE 2
Autryville
p.64
4.72
- - ---------------------------------------------------------------------------------
764326 Database Version 2.0 Date Printed: 06.21-2002 OF Page 1 of 1

The following Lagoon Sludge Nitrogen Utilization table provides an estimate of the number of acres needed for
sludge utilization for the indicated accurn uiation period Thee estimates are based on average nitrogen
c oncentratiom for each source; the number of animals in the facility and the plant available nitrogen application rates
shown in the second column
Lagoon sludge contains nutnerrts and organic natter remaining after trot and application of the effluent. At
clean out, this material must be utilized for crop production and applied at agronomic rates. In most cases, the
priority nutrient is nitrogen but other nutrients including phosphorous, copper and anc can also be limiting. Since
nutrient levels are generally very high, application of sludge must be carefully applied
Sites mist first be evaluated for their suitability for sludge application Ideally, effluent spray fields should not be
used for sludge application If this is nut possible, care should be taken not to load effluent application fields with
high amounts of copper and zutc so that additional effluent cannot be applied On sites vulnerable to surface water
moving to streams and lakes, phosphorous is a concern. Soils containing very high phosphorous levels may also be a
Concern.
Lagoon Sludge Nitrogen Utilization Table
Crop
Maximum
PA-N Rate
Ib/ac
Maximum Sludge
Application Rate
1000 gal/ac
Minimum Acres
5 Years Accumulation
Minimum Acres
10 Years Accumulation
Minimum Acres
15 Years Accumulation
Swine Farrowing-Weanling Lagoon Sludge - Standard
Can 120 bu
150
13.16
14.92
29-63
44.45
Hay 6 tan R.Y.E.
300
26.32
7.41
14.92
22.22
Soybean 40 bu
160
14.04
13.99
27.79
41.67
----------------
---------------- ------ -------------- ------------------------:----------�------ Stud Page 1 of 1
764326 Database Version 2.0 Date Printed-. 06-21-2002 Sludge

The Available Waste Storage Capacity table provide, an estimate of the number of days of storage
capacity available at the and of each month of the plan Available storage capacity is calculated as the
design storage capacity in days minus the number of days of net storage volume accumulated The start
date is a value entered by the user and is defined as the date prior to applying nu trier>ts to the frst crop in
the plan at which storage volume in the lagoon or holding pond is equal to zero.
Available storage capacity should be greater than or equal to zero and less than or equal to the design
storage capacity of the facility. if the available storage capacity is greater than the design storage opacity,
this indicates thud the plan calls for the application of nutrients that have nut yet accui iladed If available
storage capacity is negative, the estimated volume of accunndated waste exceeds the design storage volume
of the structure. Either of these situations indicates that the planned application interval in the waste
utilization plan is imonsistaerdt with the structure's temporary storage capacity.
Available Waste Storage Capacity
Source Name Swine Famwing-Wcanling Lagoon Liquid
Design Storage Capacity (Days)
Start Date 9/30
190
Plan Year
Month
Available Storage Capacity (Days) #
l
1
107
1
2
93
1
3
147
1
4
180
1
5
180
1
6
180
1
7
180
1
8
180
1
9
180
l
10
159
l
11
1 1.
1
12
1 113
* Available Storage Capacity is calculated as of the end of each month-
------------------------------------------------------------------------ - -- ------
764326 Database Version 2.0 Date Primed: 06-21-2002 Capacity Page 1 of 1

Required Specifications For Animal Waste Management
1. Animal waste shall not reach surface waters of the state by runoff, drift,
manmade conveyances, direct application, or direct discharge during
operation or land application. Any discharge of waste that reaches surface
water is prohibited.
2. There must be documentation in the design folder that the producer either
owns or has an agreement for use of adequate land on which to properly
apply the waste. If the producer does not own adequate land to properly
dispose of the waste, he/she shall provide evidence of an agreement with a
landowner, who is within a reasonable proximity, allowing him/her the use
of the land for waste application. it is the responsibility of the owner of the
waste production facility to secure an update of the Nutrient Management
Plan when there is a change in the operation, increase in the number of
animals, method of application, receiving crop type, or available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs
for realistic crop yields based upon soil type, available moisture, historical
data, climatic conditions, and level of management, unless there are
regulations that restrict the rate of applications for other nutrients.
4. Animal waste shall be applied to laud eroding less than 5 tons per acre per
year. Waste may be applied to land eroding at more than 5 tons per acre per
year but less than 10 tons per acre per year provided grass filter strips are
installed where runoff leaves the field (see USDA, NRCS Field Office
Technical Guide Standard 393 - Filter Strips.
5. Odors can be reduced by injecting the waste or by disking after waste
application. Waste should not be applied when there is danger of drift from
the land application field.
6. When animal waste is to be applied on acres subject to flooding, waste will
be soil incorporated on conventionally tilled cropland. When waste is
applied to conservation tilled crops or grassland, the waste may be
broadcast provided the application does not occur during a season prone to
flooding (see "Weather and Climate in North Carolina" for guidance).
-------------------------------------------------------------------------------�-------
764326 Database Version 2.0 Date Printed: 06-21-2002 S cation Page i o:

7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate
such that runoff does not occur offsite or to surface waters and in a method
which floes not cause drift from the site during application. No ponding
should occur in order to control odor and flies.
8. Animal waste shall not be applied to saturated soils, during rainfall events,
or when the soil surface is frozen
9. Animal waste shall be applied on actively growing crops in such a manner
that the crop is not covered with waste to a depth that would inhibit growth.
The potential for salt damage from animal waste should also be considered.
10. Nutrients from waste shall not be applied in fall or winter for spring planted
crops on soils with a high potential for leaching WasWnutrient loading
rates on these soils should be held to a minimum and a suitable winter cover
crop planted to take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking dormancy-
11. Any new swine facility sited on or after October 1,1995 shall comply with
the following: The outer perimeter of the land area onto which waste is
applied from a lagDon that is a component of a swine farm shall be at least
50 feet from any residential property boundary and canal. Animal waste,
other than swine waste from facilities sited on or after October 1, 1995, shall
not be applied closer that 25 feet to perennial waters.
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other
than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and public
right-of-ways.
15. Anima! waste shall not be discharged into surface waters, drainageways, or
wetlands by a discharge or by over -spraying. Animal waste may be applied
to prior converted cropland provided the fields have been approved as a
land application site by a "technical specialist". Animal waste shall not be
applied on grassed waterways that discharge directly into water courses,
and on other grassed waterways, waste shall be applied at agronomic rates
in a manner that causes no runoff or drib from the site.
----------------------------------_----------------------------------------------------
764326 Database Version 2.0 Date Printed: 06-21-2002 Specification Page 2 o

16. Domestic and industrial waste from washdown facilities, showers, toilets,
sinks, etc., shall not be discharged into the animal waste management
system.
17. A protective cover of appropriate vegetation will be established on all
disturbed areas (lagoon embankments, berms, pipe runs, etc.). Areas shall
be fenced, as necessary, to protect the vegetation. Vegetation such as trees,
shrubs, and other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible. Berms
and structures should be inspected regularly for evidence of erosion,
leakage, or dicscharge.
18. If animal production at the facility is to be suspended or terminated, the
owner is responsible for obtaining and implementing a "closure plan' which
will eliminate the possibility of an illegal discharge, pollution, and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected on
a regular basis to prevent breakdowns, leaks, and spills. A regular
maintenance checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other
crops for direct human consumption. however, if animal waste is used on
crops for direct human consumption, it should only be applied pre -plant
with no further applications of animal waste during the crop season.
21. highly visible markers shall be installed to mark the top and bottom
elevations of the temporary storage (pumping volume) of all waste
treatment lagoons. Pumping shall be managed to maintain the liq uid level
between the markers. A marker will be required to mark the maximum
storage volume for waste storage ponds.
--------------------------- ----- -.----------------------------------------------------- ------
764326 Database Version 2.0 Date Printed- 06-21-2002 Specification Page 3 o

22. Waste shall be tested within 60 days of utilization and soil shall be tested at
least annually at crop sites where waste products are applied. Nitrogen
shall be the rate -determining nutrient, unless other restrictions require
waste to be applied based on other nutrients, resulting in a lower application
rate than a nitrogen based rate. Zinc and upper levels in the soils shall be
monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for
optimum crop production. Soil and waste analysis records shall be kept for
a minimum of five years. Poultry dry waste application records shall be
maintained for a minimum of three years. Waste application records for all
other waste shall be maintained for a minimum of five years.
23. Dead animals will be disposed of in a manner that meets North Carolina
regulations.
-- - -------- - - - - -- -------------------------------------------------------------------
764326 Database Version 2.0 Date Printed: 06-2I-2002 Specification Page 4 o

Crop Notes
The following crop note applies to field(s): ZONE 1
Bermudagrass Coastal Plain, Mineral Soil, Poorly Drained to Somewhat Poorly Drained.
Adaptation: Effective artificial drainage MUST be in place to achieve Realistic Yield Expectations
provided for these soils -
In the Coastal Plain, hybrid bermudagrass sprigs can be planted Mar. 1 to Mar. 31. Cover sprigs 1" to 3"
deep (1.5" optimal). Sprigs should be planted quickly after digging and not allowed to dry in sun and wind.
For Coastal and Tifton 78 plait at least 10 bu/ac in 3' rows, spaced 2' to 3' in the row. Generally a rate of
30 bu/ac is satisfactory to produce full groundcover in one or two years under good growing conditions.
Tifton 44 spreads slowly, so use at least 40 bu/ac in 1.5' to 2' rows spaced 1' to 1.5' in row. For
broadcast/disked-in sprigs use about 60 bu/ac. Soil test for the amounts of lime, phosphorus, potassium
and micronutrients to apply preplant and for annual maintenance. Apply 60 to 100 lb/ac N in the
establishment year in split applications in April and July. For established stands apply 180 to 240 lb/ac N
annually in split applications, usually in April and following the first and second hay cuts. Reduce N rates
by 25% for grazing. Refer to NCSU Technical Bulletin 305 Production and Utilization of Pastures and
Forages in North Carolina for more information or consult your regional agronomist or extension agent for
assistance.
The following crop note applies to field(s): ZONE 2
Bermudagrass Coastal Plain, Mineral Soil, Moderateiv Well Drained.
Adaptation: Well -adapted.
In the Coastal Plain, hybrid bermudagrass sprigs can be planted Mar. 1 to Mar. 31. Cover sprigs 1" to 3"
deep (1.5" optimal). Sprigs should be planted quickly after digging and not allowed to dry in sun and wind.
For Coastal and Tifton 78 plant at least 10 bu/ac in 3' rows, spaced 2' to 3' in the row. Generally a rate of
30 bu/ac is satisfactory to produce full groundcover in one or two years under good growing conditions.
Tifton 44 spreads slowly, so use at least 40 bu/ac in 1.5' to 2' rows spaced I to 1.5' in row. For
broadcast/disked-in sprigs use about 60 bu/ac. Soil test for the amounts of lime, phosphorus, potassium
and micronutrients to apply preplant and for annual maintenance. Apply 60 to 100 lb/ac N in the
establishment year in split applications in April and July. For established stands apply 180 to 240 lb/ac N
annually in split applications, usually in April and following the first and second hay cuts. Reduce N rates
by 25% for grazing Refer to NCSU Technical Bulletin 305 Production and Utilization of Pastures and
Forages in North Carolina fnr more information or consult your regional agronomist or extension agent for
assistance.
------------------------------------------------------------
-----------------
7G4326 Database Version 2.0 Date Printed. 06-21-2002 Crop Note Page 1 of

The following crop note applies to field(s): ZONE 1
Small Grain: CP, Mineral Soil, low -leachable
In the Coastal Plain, oats and barley should be planted from October 154Oc-tober 30; and rye from October
15 November 20. For barley, plant 22 seed/drill row foot and increase the seeding rate by 5% for each
week seeding is delayed beyond the optimum time. See the seeding rates table for applicable seeding rate
modifications in the current NCSU "Small Grain Production Guide". Also, increase the initial seeding rate
by at least 10% when planting no -till. Oats should be planted at 2 bushels/acre and rye at 1-1 1./2
bushels/acre- Plant all these small grains at 1-1 1/2" deep- Adequate depth control is essential. Review the
NCSU Official Variety "green book" and information from private companies to select a high yielding
variety with the characteristics needed for your area and conditions. Apply no more than 30 lbstacre N at
planting. Phosphorus and potash unintended by a soil test can also be applied at this time. The
remaining N should be applied during the months of February -March.
The following crop note applies to field(s): ZONE 2
Small Grain: CP, Mineral Soil, medium leachable
In the Coastal Plain, oats and barley should be planted from October 15-October 30, and rye from October
15 November 20. For barley, plant 22 seed/drill row foot and increase the seeding rate by 5% for each
week seeding is delayed beyond the optimum tithe. See the seeding rates table for applicable seeding rate
modifications in the current NCSU "Small Grain Production Guide"- Also, increase the inittal seeding rate
by at least 10% when planting no -till. Oats should be planted at 2 bushels/acre and rye at 1-1 1/2
bushelslacre. Plant all these small grains at 1-1 1/2" deep. Adequate depth control is essential. Review the
NCSU Official Variety "green book" and information from private companies to select a high yielding
variety %ith the characteristics needed for your area and conditions. Apply no more than 30 Ibs/acre N at
Planting. Phosphorus and potash recommended by a soil test can also be applied at this time. The
remaining N should be applied during the months of February -March.
------------------------------------------
764326 Database Version 2.0 Date Printed: 06-21-2002 Crop Note Page 2 of

Y ,
�� ;�.�'�
6 • 8 U.S. - Dlametrr ((art) MEiR1C - Dlametrr (mataVE)
SPRINKLER (psl) 35 i 40 46 5o 55 6o 65 70 (b@4 25 3.0 3.5 4.0 4.5 5.0
BASE PRESSURE (psr) .38.25 4.35o 50.73 6ROO 85.25 72.50
414 Hoa1a - (7132-)
Flow (gpm)
$ 11
8.66
920
9.69
102
10.5
11.0
11.5
Dion. at is height (fl)
106
Ill
113
115
117
119
121
123
Diam. at SO height (it)
114
118
121
124
126
120
129
130
1"6 Mazda -(1N')
Flour (gpm)
10.7
11 A
12.1
12.8
13.4
14.0
14.8
15.1
Diam_ at 1.5- height (0)
I'll
117
120
123
126
129
131
133
Diem. at 6.0' height (11)
122
126
129
131
134
136
137
138
118
Flag (gpm)
13.3
ta2
15.0
15.9
16.6
17,4
18.1
15.8
Diam. at 1-5' height (ft)
118
124
127
129
134
139
142
144
Diam. at 6.V height (tt)
128
132
135
137
141
144
146
147
m Mazda - (6/16')
P-W (gpm)
1B.
17.1
182
192
20.1
21.0
21.8
22.7
Mvn. sit IS, haigtlt (1t)
12 '
130
134
137
142
146
150
153
Diam. at 8.0- height (!t)
133
137
140
143
147
151
154
155
8= Mazda - (111321)
Flow (gpm)
19.3
20.5
21.8
22.9
24.1
25.1
26.1
27.1
Diam. at 1.5 height (tf)
120
133
141
148
153
157
160
162
Diam. at 6.1y height (1t)
136
141
146
15D
155
159
162
184
•14 Moab - (Le mm)
(11a)
0.52
0.57
0.61
ON
0,70
0.73
0.5 m (m)
32.7
34.3
35.1
30.0
36.9
37.8
2.0 m (m)
35.1
36.6
37.9
30.8
39.3
39.8
t16 Mazda, - (6.4 mm)
(LIS)
0,69
0.75
0.81
0.87
0.92
0.97
0.5 m (m)
34.3
36.3
37.6
39.0
40.0
41.0
2.0 m 1m)
37.5
39,0
40.1
412
41 A
42.2
#16 Mo>o la - (7.1 mm)
(LIS)
0.B5
0.94
1.31
1.00
1.15
1.21
0.5 m (m)
35A
38.4
39.5
41.8
43.3
44.5
2.0 m (m)
39.3
40.9
41.9
43.5
44.5
45.0
#20 Nozzle - (7.8 mm)
(Us)
1.02
1.12
1.21
129
1.37
1,45
0.5 m (m)
38.3
40.5
42.0
44.0
45.8
47.1
2.0 m (m)
40.8
42.4
43A
45.5
47.0
47.4
to Mazda - (8.7 mrn)
(LIS)
1.23
1.34
1.45
1.55
1.65
1.73
0.5 rn (m)
38.9
42.2
45.3
47.4
48.8
49.B
2.0 m (m)
41.8
44.0
46.0
48.0
49.4
50A
424 Mazzla - (3/8') 024 Mazda - (9.5 mm)
Flo (Sp-) 22.4 23.9 25.3 26.7 28.0 29.3 30.4 31.6 (Lis) 1.43 1.56 1.60 1.90 1.91 2.02
Diam_ at 1.5 height (A) 130 138 145 151 156 160 166 169 0.5 m (m) 402 43.6 46.3 48.3 50.7 52.4
Diam. at GO height (t1) 138 145 150 155 160 164 167 170 2.0 m (m) 42.6 45.3 47.5 49.5 50.9 52.4
rapmbannteedFgr�mflwl Ac�/ asde oetnad LomYer xAw/ corkhbom SVawn h 1 . (- bl0"
p mwm and rwzzb size. Spni9jW p&rkvmanoa tests were connlncmd rn ancadwwa mO doer American Saaery d AQ�t�um/ F��a
s1$rmbrd S396.1 and are rppresaer=&w d pmducbon a1 dw bma 0/prbtea0m. Dwn wlers shown am Jorsaw chid straoV burs naznbs and
fi uenl mama Mm*Y J. Odw no22les ar>o%r vane comdinabi m are available; cmmutl1ackvy forspeafic pwIb1marwJ dale.
Sennrrlger IfrouiYon (407),?93-5555- 00-70EFF 9

21-JUII-2002 W46 FRO"CQEMR FRO
�A11E13QV
9104860707 T-681 P.002/002 F-123
P35/65 PERFORMANCE DATA
MODEL P35 (port C-rcle) - 3/4' w! VANE - 274 TWECTORY ..- 1Oorc golharoa from :prinklar an 12• rizar -- rc
w 11/w 3A6' 13161' 7f3r
'An
P9
I GPM
94
f'
G?h
R4A
FL
GPY
la
1r.
GPI>W0.
GPM
ull
Fr.
30
1 3.9
41
4.6
as
5.6
4a
6.5
46
7.5
46
35
4.2
42
5.0
41
6.0
AS
7.0
47
8.0
48
40
4.5
43
1 5.3
46
$.A
47
7.5
48
8.6
52
41
4.73
AA
5.6
47
6.5
43
5.0
49
9.2
53
50
A.9
45
6.0
48
7.2
49
1 8.4
50
9.6
5a
55
5.2
46
6.3
49
7.5
49
8.8
51
10.0
54
60
5.4
47
6.6
50
7.9
50
9.1
SA
10-5
55
65
5,6
48
6.9
50
8.2
51
9.5
54
10.9
36
70
5.8
49
7,1
51
8.6
52
9.8
55
11.3
57
75
6.1
50
7.4
52
8.8
52
1.0.2
55
11.a
57 ,
80
0.3
51
7.6
52
9.1
53
10.5
56
12.1
58
40DEL P65 (part C'1rt1a) - 1' W/ VANE 24' TTWEGTOiY- (06m gcrwrid frv.n cpins14r on 18' m4r- no -ind)
` 7l32' 1M" 913r 19161' 5AC 21m4' 11132' 22161' 113'
05;
GNI
u10
Fr.
LIM
apY
ma
F1
UM
ba
FL
WY
dAG
.1
"Iri
no
fiPk
"a
H,
KAU
FE
uQ
FE
30
7.6
51
9.9
53
17,4
56
13.7
57
15.3
57
16.5
59
15.0
60
1T6
61
21.G
62
35
8.7
53
:0.7
55
13.4
58
14.7
$9
16.A
00
17.5
62
19.4
6I
21.0
63
22.6
6•.
40
5.3
55
11.5
57
IA.4
61
15.7
63
17.7
63
19A
65
20.8
55
22.6
66
24.3
68
45
9.3
57
17.1
59
15.1
62
16.7
64
18.7
65
202
67
22.0
67
23.9
6d
25.7
70
50
9A
59
12 8
62
15.9
64
17.7
67
19.7
67
21.3
69
23.3
70
23.3
71
27A
73
55
10.3
6�
13.5
63
16.8
66
18.5
68
20.7
69
22.3
71
2-1.3
72
26.3
73
28.2
74
60
10.8
62
14.1
64
17.6
68
19.3
69
21.6
77
23.3
73
25.4
74
27.5
76
29.3
7d
65
11,3
63
14.7
66
18.3
69
20.1
71
22,5
73
24_3
74
26.5
76
28.5
77
39.5
73
7fl
11 7
65
15 3
68
19.0
71
20.9
73
23A
75
25.3
7!
27.6
78
29.6
79
31.9
et
15
12.1
66
15.8
69 1
19.6
72
V .7
74
24.1
76
26.1
77
20.6
79
30.7
80
33.0
02
80
12.5
68
16.3
71 1
20.3
14
22.5
76
2a.9
78
27.0
80
79.5
31
31.7
8:
34.1
83
NOTE: S-mied performance UT WE PRESSURE.
PLEASE REFER TO 'WARRANTY AND D15CLAiMER" STATEMENT ON PAGE 16
i
[ clr lrrigatiaa (arp. 848 Airporr Rd, Wcji a lvcll6, INA 99362-2271 UU Tal: 509.525.765E Fax: [phone] f 11mi1: infaigie:Isanirrigateon.alm Web rih: wrr adlaalyd0atianlnm
c
Ab

500
Farrow
to
Wean

4CDA Agronomic Division 4300 Reedy Creek Road Raleigh, NC 27607-6465
6/18/02
733-2655
Grower: Horne, Marshall
2595 Lamb Rd.
Garland, NC 28441
Waste Analysis ort
Y
Farm:
County
Copies To:
No: w09497 W
ample Q
N
P K CO
S
FP Mn Zn
CU 9
Mb
Cl
C
Tatar 451
174 606 183
69.0
68.9
12.7 1.16 4.00
0.94 1.08
IN -N
Paste Code.
-NH4
LS
-NO3
No Ni Cd
Pb
Al
Se Li pi I
S5 C: N
DM%
CCf%
ALE(Kgol,
tescrlption:
OR- N
205
7.09
Nine Lagoon Liq•
Urea
recommendations:
Nutrients Available for FirstGrop
IbO00U gglions
Other Elements
lbs17000
gallons
ppHcation Method
N F20s K20 Ca M'g S Fe
Mn
In
Cu
a Ma Cl
Na Ni Cd
Pb
Al
Se Li
Irrigation
1.9 2.3 4.9 1.1 0,40 0.40 0.07
0.01
0.03
0.01
001
1.7
Please be sure to fill out the waste analysis information sheet completely. We need to know the type of waste (waste codes are listed on twk of the form),
a brief description, and the
application
metnod(s)
that you
intend to use (listed on lower right side of front). Thank you very much.
ample Info.
Laboratory Results {parts per million unless otherwise noted)
ample Q
N P K Ca
S
Fe Mn Zn
CU 8
Mh
Ci
C
Total 36.5 10.2 36.3 86.7
19.9
10.2
1.50 0.25 0.53
0.11 0.32
IN -N
Vaste Code:
-NH4
LS
-NO3 Na Ni Cd
Pb
Al
Se Li pil
SS C:N
DM%
CC[%
ALE(Kg21
bwiption:
OR-N 21.2
642
Nine Lagoon Liq.
Urea
recommendations:
Nutrients Available for First Crop
lbs17000 allons
Other Elements
IW10009allons
pplication Method
N F205 K20 Ca Mg 5 Fe
Mrr
Zn
Cu
a Mo Cl
Na Ni Cd
13b
At
Se Li
Irrigation
0.15 0.14 0.29 0.51 0.12 0,06 001
T
T
T
f
I 0.18
The pH of the lagoon liquid is below the ideal range for bacterial action and waste treatment. Gradually adjust pli by adding 1 lb. of agricultural lime per 1000 cu, ft of liquid remaining in the lagoarn. Sample the lago
monthly and continue to adjust pH until it is within the desired range of 7 0 8.0.

!,
WASTE UTILIZATION PLAN AMENDMENT
This amendment is included to address the wastewater that may need to be pumped, for
maintenance purpose, from the abandoned lagoon.
jaggon # 5urf4ce Area
0.60 Acres
Rainfall in excess of evaporation during 12 month period in Sampson County = 11.23
inches (0.94 foot)(From Rainfall -Evaporation Chart for Area 3).
Volu A of Rainfall to be Pumped From Abandoned L gQn
1 = 182,982.65 gallons
PAN from Waste Analysis Report for Abandoned Lagoon = 0.15 N/1000 gallons.
Total PAN from the abandoned lagoon that may need to be applied per year for
maintenance = 27.4 lbs N.
The PAN deficit from the existing waste utilization plan is (-721 Is N). The new deficit
is (-693.6 lbs N). Therefore, there is adequate land included in the existing waste
utilization plan to treat the wastewater pumped, for maintenance, from the abandoned
lagoon.
O
MARSPHALL HORNE (OWNS) DATE
7, p Z
JCFMCAL SPfi ,IALIST DATE

` Michael F. Easley, Governor
William G_ Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E., Director
Division of Water Quality
3 ly 23, 2002
AUG 22002
Marshall Home ; f. DkfvQ
Marshall Home
2595 Lamb Rd
Garland NC 28441
Subject: Certificate of Coverage No. AWS820381
Marshall Horne Faun
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
Dear Marshall Horne:
In accordance with your application received on August 11, 1999, we are forwarding this Certificate of
Coverage (COC) issued to Marshall Horne, authorizing the operation of the subject animal waste
collection, treatment, storage and land application system in accordance with General Permit
AWG100000. This approval shall consist of the operation of this system including, but not limited to,
the management of animal waste from the Marshall Horne Farm, located in Sampson County, with an
animal capacity of no greater than 500 Farrow to Wean and the application to land as specified in the
Certified Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
The facility's CAWMP meets all requirements in place at the time of certification. However, it appears
that the irrigation system on site may not adequately cover all acreage listed in the Waste Utilization Plan.
The owner should begin to address this inconsistency as soon as possible.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This request
shall be made within 30 days of notification by the Division.
��
Non -Discharge Permitting Unit
1617 Mail Service Center, Raleigh, NC 276W1617
DENR Customer Service Center
An Equal Opportunity Action Employer
tntemet httpJ/h2o.enr.nc.state.us/ndpu
Telephone [phone] Fax [phone]
Telephone i 800 623-7748
50% recycled/101/6 post -consumer paper

This COC is not automatically transferable. A name/ownership change application must be submitted to
the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual non -discharge permit by contacting the engineer listed below for information on
this process. Unless such' a request is made within 30 days, this COC shall be final and binding.
The subject farm is located in the Fayetteville Regional Office. The Regional Office Water Quality Staff
may be reached at [phone]. If you need additional information�conceining this COC or the
General Permit, please contact Michelle Barnett [phone] ext. 544. i.
Sincerely,
Alan W. Klimek, P.E.
cc_ (Certificate of Coverage only for all cc's)
Sampson County Health Department
Fayetteville Regional Office, Water Quality Section
Sampson County Soil and Water Conservation District
Water Quality Central Files
NDPU Files

State of North Carolina
Department of Environment and Natural Resources
Division of Water Quality
Non -Discharge Permit Application Form
(THIS FORM MA Y BE PHOTOCOPIED FOR USE AS AN ORIGINAL)
General Permit - Existing Animal Waste Operations
The following questions have been completed utilizing information on file with the Division. Please
review the information for completeness and make any corrections that are appropriate. If a
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
1. GENERAL INFORMATION:
1.1 Facility Name: Marshall Horne Farm
1.2 Print Land Owner's name: Marshall Home
1.3 Mailing address: 2595 Lamb Rd
City, State: Garland NC
Telephone Number (include area code): 529-9281
Zip: 2W I
1.4 County where facility is located: Sampson
1.5 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a
copy of a county road map with the location of the farm identified): On the north side of SR 1135 approx..5 mile east of
its intersection with Hwy 701. south of Clinton, NC.
1.6 Print Farm Manager's name (if different from Land Owner):
1.7 Lessee's / Integrator's name (if applicable; please circle which type is listed): Murphy Family Farms
1.8 Date Facility Originally Began Operation: 01/01/82
1.9 Date(s) of Facility Expansion(s) (if applicable):
2. OPERATION INFORMATION:
2.1 Facility No.: �82_ (county number); _381 (facility number).
2.2 Operation Description: Swine operation
If arrow to Wean
500- Certified Design Capacity
Is the above information correct? [:] yes; F--Jno. If no, correct below using the design capacity of the facility
The "No. of Animals" should be the maximum number• for which the waste management structures were'designed.
Type of Swine
0 Wean to Feeder
0 Feeder to Finish
0 Farrow to Wean (# sow)
0 Farrow to Feeder (# sow)
No. of Animals Type of Poaltry No. of.Animals
0 Layer
0 Farrow to Finish (# sow)
Other Type of Livestock on the farm:
0 Non -Layer
0 Turkey
Type of Cattle
0 Dairy
0 Beef
No. of Animals:
Nn of Anim;%tc
FORM: AWO-G-E 5/28/98 Page 1 of 4 82 - 381

-V
3.
2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): 24 ; Required Acreage (as listed in the AWMP): 9.3
2.4 Number of lagoons/ storage ponds (circle which is applicable): k
2.5 Are subsurface drains present within 100' of any of the application fields? YES or a circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES or*NOease circle one)
2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, ds, etc.) (Swine Only)
YES,,+ NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited? t�(
What was the date that this facility's land application areas were sited? 4 ."Z�
REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
Applicants Initials
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CA WMP, it must be completed prior to submittal of a general permit
application for animal waste operations.
The CAWMP must include the following components. Some of these components may not
have been required at the time the facility was certified but should be added to the
CAWMP for permitting purposes:
3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application.
3.3.4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application field.
3.3.8 The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.3.10 A site schematic.
3.3.11 Emergency Action Plan.
3.3.12 Insect Control Checklist with chosen best management practices'noted.
3.3.13 Odor Control Checklist with chosen best management practices noted.
3.3.14 Mortality Control Checklist with the selected method noted.
3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility.
3.3.16 Operation and Maintenance Plan.
If your CAWMP includes any components not shown on this list, please include the
additional components with your submittal.
FORM: AWO-G-E 5/28/98 Page 2 of 4 82 - 381

x
Facility Number_ 82 - 381
Facility Name: Marshall Home Farm
4. APPLICANT'S CERTIFICATION:
i, 64_cllha 1l 1< (Land Owner's name listed in question 1.2), attest that
this application for AtmAoxk 4qyjr, Fmo, (Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned to me as incomplete.
Signature Date
5. MANAGER'S CERTIFICATION: (complete only if different from the Land Owner)
(Manager's name listed in question 1.6), attest that this
application for (Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned as incomplete.
Signature Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
It
FORM: AWO-G-E 5/28/98 Page 3 of 4 82 - 381

1
pe'''btt';ne
Producer. �gL•S4a 1 � d'z-'TL'.) L
Location: z595 La,� 7J. Gwd&OJ
Telephone: 9/e
Type Operation:
..
Number of Animals:.Do
(Design Capacity)
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface and/or groundwater. The plant nutrients in the animal waste should
be used to reduce the amount of commercial fertilizer required for the crops in the fields
where the waste is to be applied This waste utilization plan uses nitrogen as the limiting
nutrient. Waste should be analyzed before each application cycle. Annual soil tests are
strongly encouraged so that all plant nutrients can be balanced for realistic yields of the
crop to be grown.
Several factors are important in implementing your waste utilization plan in order to
maxtmi�p the fertilizer value of the waste and to ensure that it is applied in an -
environmentaily safe manner. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply more nitrogen than the crop
can utilize. Soil types are important as they have different infiltration rates, leaching
potentials, cation exchange capacities, and ava-lable water holding capacities.. Normally
waste shall not be applied to land eroding at greater than 5 tons per acre per year. With
special precautions, waste may be applied to land eroding at up to 10 tons per acre per
year. Do not apply waste on saturated soils, when it is raining, or when the surface is
frozen. Either of these conditions may result in runoff to surface waters which is not
allowed under DFM regulations. Wind conditions should also be considered to avoid drift
and downwind odor problems. To maximize the value ofuutrients for crop production '
and to reduce the potential for pollution, the waste should be applied to a growing crop or
applied to bare ground not more than 30 days prior to planting. Injecting the waste or
disldng will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. Acreage requirements should be based on the waste analysis
report from your waste management facility. Attached you will find information on
proper sampluig techniques, preparation, and transfer of wane samples to the lab for
analysis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A
NCAC 21J.0217 adopted by the Environmental Management Commission.

N
Amount of Wtrrte Produced Per Year(gallons ft3tons. etc.
�N
00 animals X(o of (=� wastelanimaUyear = 3 2± (a�3j wastdyear.
Amount of Plant Avaflable Nitrogen (PAN) Produced Per Year
5 0 o animals X' - Ibs. PAN/animWyear =LIB lbs. PAN/ymr. (PAN from bI C. Tech.
Guide-Std. 633)
Applying the above amount of waste is a big job. You should plan time and have
appropriate equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on the crop to be grown
and surfaceapplication:
Table I: ACRES OWNED BY PRODUCER
Tract Field Soil Crop Lbs. N Acres Us. N Month of
# No_ Tvne Per Ac_ * Utilized Anvlication
Total I 1z•G- o
* This N is from animal waste only. If nutrients from other sources such as commercial
fertilizer are applied, the)► must be accounted for. N must be based on realistic yield
rxp ectation.
NOTE. The applicator is cautioned that P and K ma), be ot•er applied while meeting the N
requirements. Beginning in 1996 lire Coastal Zone Management Act will require farmers in
some eastern counties of North Carolina to have a nutrient management plan that addresses
all nutrients. This plan only addresses Nitrogen.
4(Lc-�

•------------- -
Table 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement vdth adjacent landomer mast be aita&td)
(Required only if operator does not own `
adequate land [see Required Specification 2])
Traot Field Soil Crop Us. N Acres Us. N Month of
• See footnote for Table 1.
Totals from above Tables
Acres Us. N
utilized
Table 1 /,Z- •4 5 ,�
Table 2
Total z. (., /-a55.0
Amount of Produced Z r700 .p
Surplus r Deficit / �,o
NOTE.- The Waste Utilization Plan must contain provisions jar periodic land
application of sludge at agronomic rates. The sludge will be nutrient rich and will
require precautionary nreasrrres to prevent over application of nutrients or other
elements.

See attached map showing the fields to be used for the u0zalion of waste water.
4
Application of Waste by Irrigation
Field Soil Type Crop Application Application
TBTS TABLE IS NOT X�ED IF WASFE LS NOT BE 40 APP= BY IRRIGATION, HOWEVER A SA2LAR TABLE WILL
BE NEEDED FOR DRY LrrM OR SLURRY.
Your facility is designers for23> days of temporary storage and the temporary storage
must be removed on the average of once every (_ MONTHS. In no instance should
the volume of waste being stored in your structure exceed Elevation
Call the local Natural Resources Conservation Service (formerly Soil Conservation
Service) or Soil and Water Conservation District office after you receive the waste
analysis report for assistance in determining the amount per acre to apply and .the proper
application rate prior to- applying the waste.
,/V . — A- "t . f

IMMMMMMK�����MAM relo"o MET
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters ofthe state by runofy drift, manmade
conveyances, direct application, or direct discharge during operation or land
application. Any discharge of waste which reaches surface water is prohibited. Illegal
discharges jare subject to the assessment of civil penalties of $10,000 per day by the
M ision of Environmental Management for every day the discharge continues.
2. The Field Office must have documentation in the design folder that the producer either
owns or has long term access to adequate land on which to properly apply the waste.
If the producer does not own adequate land to properly dispose of waste, he shall
provide NRCS with a copy of a written agreement (sample enclosed) with a landowner
who is within a reasonable proximity, allowing him/her the use of the land for waste
application for the life expectancy of the production facility. It is the responsibility of
the owner of the facility to secure an update of the Waste Utilization Plan when there
is a change in the operation, increase in the number of animals, method ofudlization,
or available land.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for realistic
crop yields based on soil type, available moisture, historical data, climate conditions,
and level of management, unless there are regulations that restrict the rate of
application for, other nutrients.
4. Animal waste may be applied to land that has a Resource Management System (RMS)
or an Alternative Conservation System (ACS).' If an ACS is used the soil loss shall be
no greater than 10 tons per acre per year and appropriate filter strips will be used
where runoffleaves the field. These filter strips will be in addition to "Buffers"
required by DEM. [See FOTG Standard 393 - Filter Strips and Standard 390
(Interim) - Riparian Forest Buffers.]
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when the wind is blowing.
6. When animal waste is to be applied on acres subject to flooding, it will be soil
incorporated on conventionally tilled cropland. When applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not
occur during a -season prone to flooding. (See "Weather and Climate in North
Carolina" in the Technical Reference - Environment hle for guidance.)

-
REQUIRED SPECIFICATIONS
cCo
7. liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
nmoHdoes not occur offsite or to surface waters and in a method which does not
cause drift from the site during application. No pondiag should 'occur in order to
control conditions conducive to odor or Qies and provide uniformity of application-
S. Animal waste shall not be applied to saturated soils, during rainfall events, or when
the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that no
more than 20 to 25 percent of the Ieaf area is covered.
I0. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste nutrient loading rates ou these.soils should
be held to a minimum and a suitable winter cover crop planted to take up released
nutrients. Waste shall not be applied more than 30 days prior to planting of the crop
on bare soil.
11. Animal waste shall not be applied closer than 25 feet to surface water. This distance
maybe reduced for waters that are not perennial provided adequate vegetative filter
strips are present. (See Standard 393 - Filter Strips)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste Shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and public right-of-
ways.
15. Animal waste shall not be discharged into surface waters, drainageways or wetlands by
a discharge or by over -spraying. Animal waste may be applied to prior converted
wetlands provided they have been approved as a land application site by a "technical
specialist": Animal waste should not be applied on grassed waterways that discharge
directly into water courses, and only then at agronomic rates provided the application
causes no nwoffor drill from the site.

w.,_.. MMIA
8
REQLTIRED SPECIFICATIONS
(continued)
:r
16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc.,
shall not bq discharged into the animal waste management system
17. Lagoops and other uncovered waste containment structures must maintain a ma>dffirm
operating level to provide adequate storage for a 25-year, 24-hour storm event in.
addition to the one (1) foot mandatory freeboard.
18. A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). If needed, special vegetation shall be
provided for these areas and shall be fenced, as necessary, to protect the vegetation.
Vegetation such as trees, shrubs, and other woody species, etc. are limited to areas
where considered appropriate. Lagoon areas should be kept mowed and accessible.
Lagoon berms_and structures should be inspected regularly for evidence of erosion,
leakage, or discharge.
19. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
20. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks, and spills. A regular maintenance checklist should
be kept on site.

WASTE iJTI tI-- ON PLAN AGREEMENT
Name ofFarm:+�
Omer/Manager Agreemenf
I (we) understand 'and will follow and implement the specification and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. I (we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction ofnew facilities will require a new
certification to be submitted to the Division of Environment Management (DEM) before
the new animals are stocked. I (we) also understand that there must be no discharge of
animal waste from this system to surface wasters of the state from a storm event less
severe than the 25-year, 24 hour storm. The approved plan will be filed on -site at the
farm office and at the office of the local Soil and Water Conservation District and will be
available for review by DEM upon request.
Name of Facility dwner: A A l
(Please print)
Signature:
Name of Manager(If different from owner):
Date:
Signature: , Date:
Name of Technical Specialist: (Please print)
Affiliation:
Address (Agency):
0
Signature: Date: ZD- 7-3—

WASTE U-MIZAMN AGREEMENT
(Needed only ifadMonal land has to be leared. etO
I, hereby give permission to
apply animal waste fromhis Waste Utilization System on acres of my land for
the duration oftime shown below.
I understand that this waste contains nitrogen, phosphorous, potassium, and other trace
elements and when properly applied should not harm my land or crops. I also understand
that the use of waste will reduce my need for commercial fertilizer.
Adjacent Landowner: Date:
` Waste Producer. Date:
Technical Representative: Date:
SWCD Representative: Date:
Term of Agreement: 19 to _ _ , 20
minimum of Ten Years on Cosy Shared Items)
(See Required Specification No. 2.)
i

4
Table 1: ACRES OWNED BY PRODUCER.
Tract Field Soil Crop Lbs. N Acres . Lb& N Month of.
■
9
4

7' 4k, 4
ins
Sam
May-,
Ar W
Jr
- -, X!
Q- A
!?� No,
lot
t-P
4!
Mot
loth 11 Q
.1 L
iS
*,,Aar yd .1+
rt�A
r
r �17
M yQui q4j.. iylwiqjr
So•
41
xf-A
.)
to I,-
0
n
i,T"
•• a
.is tW Ak 1,1v•I
.01 'no tons call .4
koor isml-
%
-qL A
: N WN
`.--�-,.. W" ,y� - , --.-
i
o
".r
'..
%"Ok
,e 11'.� ;V.r:Pp o
PNr
N41 io"
fit
0 01A I W
sow? q 0
1. 111
j,
J- "L4
qt
.P
•P
ro:,:4 'p, � t :T, 'a
At -, 4 V--V
Xt

NUA
Mac
. Lin N°A Au 1
Px _ IT I� of q NuA y �� J1 IU Pt {
In y MaC
Jo
Ci,A (' IC,' � Y
1 WaB Ra �� `V
-: :kF - -• al -' ,'{ :\ �� ChA ChA W
r Tr' .Jti GuA - to
1 Nog
%ChA Wall '
C° t:.:. 1 Wan
a IT `..
pl y#J,.... iy Liu
' ••�' � ChA � �': . �lt�r�' • •.• I Ra ••' m'� �3
M1 Tr �JD ChA Mae �yy Lna
euA A° o Mac W %` 1 '10 ChA
y Wan
ChA i n ` 9'•• _ •'� .�'� Na \ I, lr ChA ChA
*; �r � ,�� 1. r Lm {J _ 0 IT
1459 J01KaA r{�-Tf Au , `. Jo
G!C Lm
ChA
WaFj
Lm
CnA
- /.-
lu Ja 1u Lm TI la ''I'J ` .-.
ChA ChA Gm. la r J
`,A Ju �• h, TF
ChA ChA
ChA �y• �r nA Ly
l0 1T V : Lm 1
`w KaA
KRA till
lu ��• t 1' lu \ 1T
jo
•"```'� `'ti Lm' KaA Jr to
t TTk f;;Y� :y gym, i . J ChA
MIC ` -
Lm KaA
Jo CkA
A KaA CIA JTIN to
1 r
HuB ' +k ;oA E311 In r V { lu 1T (\
\ .-1T
fA{'_it -WaBri.ChA CnA
i-y �Tj;�� ''' to I 1
Ro HaA
i Wa6 V r� r Jo rm
Pl1'. KaA }
Au ChA �. ChA 1T
.� dB BOB :.1;,` ., t ., 1�•}ir I .';u, !
ChA
LaA Wa / '.Lrfs ; m L
Wall - , Wall F0 CIIA I
Cali ELI Jo till l 1
L Wu f'.• �/� Ly pa lr= / \ IT
Wa ? jj y f( t V c1,A
GhA-rrti;!rli; r� y Ju w 4W ChA
r n n I Jo
•-.'��' 1n'xr
NnA T,i�•rSQ9x Wo o Wol ifi _ rli LIn JCIiA. �I 1T
p�• ,{{ T°
BYi . s{3�S'+i•4 r �'' °Ov Y y 4 lice 1TfJD
/J//

f"LLLAAGIA IV &406V 1,Aµllµb VLIIVLLV i L"I. vva ----
(Please type or print all information that does not require a signature)
he of Farm: /" \A w
Owner(s) Name: t l A n 'W f—
Mailing Address: s 5 9e. L.A f, L 2 m.
r�
.0
Facility No: 8 7- -381
Phone No: ' 5z9- 9z-eI
Farm Location: County Farm is located in: 140,o..-/
Fourteen Digit Hydrologic Unit: c`7�-t�, 3 pan • a o - r1d 1 r j
Latitude an� Longitude: 3`f Y 7 S6,'r � 75 yyr /o Jl Integrator: A h -4,: ! r4Kr,5
Please attach a copy of a county road map with location identified and describe below (Be specific:
Operation Description:
Type of Swine No of Animals
Q Wean to Feeder
o Feeder to Finish
arrow to'Wean 600
o Farrow to Feeder
Q Farrow to Finish
o Gilts
0 Boars
Type of Poukry
OUyer
opullets
No of Animals Type of Came No of Animals
oDairy
oBeef
Other Typc of Livestock:_ Number of Animals:
Acreage Available for Application: 2 Required Acreage: .3
Number of Lagoons/Storage Ponds: I , D Total Capacity: 2-Ce_4, Y' i Cubic Feet (ft3)
Are subsurface drains present on the farm: YES or NO (please circle one)
If YES: are subsurface drains present in the area of the or SPRAY FIELD (please circle one)
Owner/Manager Agreement
I(we) verify that all the above information is correct and will be updated upon changing. I (we) understand the operation and maintenance
procedures established in the approved animal waste management plan for the farm named above and will implemerrt_these procedures. I (we)
know that any expansion to the existing design capacity of the waste treatment and storage system or construction of new facilities will require a
new certification to be submitted to the Division of Environmental Management before the new animals are stocked. I (we) understand that there
must be no discharge of animal waste from the storage or application system to surface waters of the state either directly through a man-made
conveyance or from a storm event less severe than the 25 year, 24-hour storm and there must not be run-off from the application of animal
waste. I (we) understand that run-off of pollutants from lounging and heavy use areas must be minimized using technical standards developed by
the Natural Resources Conservation Service. The approved plan will be filed at the farm and at the office of the local Soil and Water
Conservation District. I (we) know that modification must be approved by a technical specialist and submitted to the Soil and Water Conservation
District prior to implementation. A change in land ownership requires written notification to DEM or a new certification (if the approved plan is
changed) within 60 days of a title transfer.
Name of Land O
-Iture:
of Manager
Signature:
AWC —August , 91
Date: I v- 23 ` ?
Date: la -'a 3-

t eennicai j3YCc14><i5L .-,Gi L.AL,.."L-'L%Y.A
As a technical specialist designated by the North Carolina Soil and Water Conservation Commission pursuant to 15A
NCAC 6F .ODOS, I certify that the animal waste management system for the farm named above has an animal waste
management plan that meets or exceeds standards and specifications of the Division of Environmental Management (DEM) as
specified in 15A NCAC 2H.0217 and the USDA -Natural Resources Conservation Service (MRCS) and/or the North Carolina
Soil and Water Conservation Commission pursuant to 15A NCAC 214.0217 and 15A NCAC 6F .0001-.0005. The following
I elements are included in, the plan as applicable. While each category designates a technical specialist who may sign each
certification (SD, SI, WUP, RC,n the technical specialist should only certify parts for which they are technically competent.
II. Certification of Design
A) Collection Storave Treatment System
Chethe appropriate box
Existing facility without retrofit (SD or WUP)
Storage volume is adequate for operation capacity; storage capability consistent with waste utilization requirements.
() New, expanded or retrofitted facility (SD)
Animal waste storage and treatment structures, such as but not limited to collection systems, lagoons and ponds, have
been designed to meet or exceed the minimum standards and specifications.
Name of Technical Specialist (Please Print)
4A�3 � (;;A
Affiliation:
Date Wok Completed:
Address(Agency)
Phone No: 'a r 63z - Y-9 Z
Signature:
Date: rl
B) !And on Site
The plan provides for minimum separation (buffers); adequate amount of land for waste utilization; chosen crop is
suitable for waste management; hydraulic and nutrient loading rates.
Name of Technical Specialist
(Please Print): 4,A CG A ,,
Affiliation:
Date Work Completed:
Address (Agency):T4
AARi-!-, II$ A C. ,2 SPhone No:
Signature:
Date: �p-Z-S�cl .
C) Runoff Contra _ xterior Lots
Check the appropriate box
O Facility without exterior lots (SD or WUP or RC)
This facility does not contain any exterior lots.
() Facility with exterior lots (RC)
Methods to minimize the run off of pollutants from lounging and heavy use areas have been designed in accordance
with technical standards developed by NRCS.
Name of Technical Specialist (Please Print):
Affiliation: Date Work Completed:
Address (Agency): Phone No.:
Signature: Date:
AWC -- August 1, 1997 2

D) Application and Handlim Equipment
/ . Check the propriare box `
LExisting or expanding faciiit xith existing waste application equipment (WUP or I)
Animal waste application equipment specified in the plan has been either field calibrated or evaluated in accordance
with existing design charts and tables and is able to apply waste as necessary to -accommodate the waste managem_ ent
i
plan: (existing application equipment can cover the area required by the plan at rates not to exceed either the
specified hydraulic or nutrient loading rates, a schedule for timing of application has been established; required buffers
can be maintained and calibration and adjustment guidance are contained as part of the plan).
O New, extaanded, or existing facility without ezistini? waste anniiccation equipment for spray irrigation (I)
Animal waste application equipment specified in the plan has been designed to apply waste as necessary to
accommodate the waste management plan, (proposed application equipment can cover the area required by the plan at
rates not to exceed either the specified hydraulic or nutrient loading rates: a schedule for timing of applications has
been established; required buffers can be maintained; calibration and adjustment guidance are contained as part of the
plan).
{) New_,expanded,or existing facility without existing waste application equipment for land k2reading not using spry
irrigation. (WUP or I)
Animal waste application equipment specified in the plan has been selected to apply waste as necessary to
accommodate the waste management plan; (proposed gpplication equipment can cover the area required by the plan at
rates not to exceed either the specified hydraulic or nutrient loading rates; a schedule for timing of applicaions has
been established: required buffers can be maintained; calibration and adjustment guidance are contained as part of the
plan).
Name of Technical Specialist (Please Print):
A
Affiliation:
Date Work Completed:
Address(Agency): dA 1Za{.� .C_ -lipPhone
No: 5�-L _ 1t
Signature:ZLOA
Date: _ .Z.� w�rl
E)
The waste mansem .s facility includes a Waste Management Odor Control Checklist, an Insect Control
Checklist ortaility Management Checklist and an Emergency Action Plan. Sources of both odors and insects have
been evaluated with respect to this site and Best Management Practices to Minimize Odors and Best Management
Practices to Control Insects have been selected and included in the waste management plan. Both the Mortality
Manangemeut Plan and the Emergency Action Plan are complete and can be imolemented by this facility.
Name of Technical Specialist (Please Print):
Affiliation:
Date W k Completed:
Address (Agency):�D a Ana ! 7�.(, z°
Phone No.: )b - 53 2
Signature:
Date: 11) - 23
F) Written Notice Qf New or Expo'ding Swine Farm t
The following signs lock is only to be used for new or expanding swine farms that begin construction after June
21, 1996. If the Ocility was built before June21, 1996, when was it constructed or last expanded . I(we)
certify that I(we) have attempted to contact by certified mail all adjoining property owners and all property owners
who own property located across a public road, street or highway from this new or expanding swine farm. The notice
was in compliance with the requirements of NCGS 1067805. A copy of the notice and a list of the property owners
notified is attached.
Name of Land Owner:
Signature: Date:
Name of Manager (if different from owner):
Signature: Date:
AWL: — August 1, 1997

III. Certification of Installation
A) Collection, Storage, Treatment Installation
ew, expanded or retrofitted facili (Sl)
Animal waste storage and treatment structures such as but not. limited to lagoons and ponds, have.been installed in
accordance with the approved plan to meet or exceed the minimum standards aid specifications.
For existing facilities without retrofits, no certification is necessary.
Name of Technical Specialist (Please Print):
Affiliation: Date Work Completed:
Address(Agency): Phone No.:
Signature: Date:
B) Land Application Site (WUP)
Check the appropriate box
The cropping system is in place on all land as specified in the animal waste management plan -
Conditional Approval: all required land as specified in the plan is cleared for planting; the cropping system as
specified in the waste utilization plan has not been established and the owner has committed to established the
vegetation as specified in the plan by (month/day/year); the proposed cover crop is appropriate for
compliance with the waste utilization plan.
() Also check this box if appropriate
if the cropping system as specified in the plan can not be established on newly cleared land within 30 days of
this certification, the owner has committed to establish an interim crop for erosion control;
Name of Technical Specialist(Please Print): - t} LI
Affiliation: Date Wok Completed:
Address(Agency): D,
Phone No.: 7! v S 3 -L, — Y r i
Signature: f��l Date: �a _ �.�—g rl
This following signature block �rtly to be used when the box for conditional approval in III.B above has beers checked.
I (we) certify that I (we) have committed to establish the cropping system as specified in my (our) waste utilization plan, and if
appropriate to establish the interim crop for erosion control, and will submit to DEM a verification of completion from a
Technical Specialist within 15 calendar days following the date specifed in the conditional certification. I (we) realize that
failure to submit this verification is a violation of the waste management plan and will subject me (us) to an enforcement action
from DEM.
Name of Land Owner: -
Signature: Date:
Name of Manger (if different from owner):
Signature: Date:
AWC -- August 1, I997 4

a) Runoff Controls from Exterior Lots (RC)
Facility with exterior lots
Methods to minimize the nun off of pollutants from lounging and heavy use areas have been installed as specified in
the plan.
For facilities without exterior lots. no certification is necessary.
Name of Technical Specialist (Please Print):
Affiliation: Date Work Completed:
Address(Agency): Phone No.:
Signature: Date: .
D) Application and Handling Equipment Installation (WUP or 1)
Check appropriate block
Animal waste application and handling equipment specified in the plan is on site and ready for use; calibration and
adjustment materials have been provided to the owners and are contained as part of the plan.
(} Animal waste application and handling equipment specified in the plan has not been installed but the owner has
proposed leasing or third party application and has provided a signed contract; equipment specified in the contract
agrees with the requirements of the plan; required buffers can be maintained, calibration and adjustment guidance have
been provided to the owners and are contained as part of the plan.
() Conditional approval: Animal waste application and handling equipment specified in the plan has been purchased
and will be on site and installed by _ (month/day/year), there is adequate storage to
hold the waste until the equipment is installed and until the waste can be land applied in accordance with cropping
system contained in the plan; and calibration and adjustment guidance have been provided to the owners and are
contained as part of the plan.
Name of Technical Specialist (Please Print):
Affiliation:
Date Ikork Completed:
Address(Agency):-F� . � , (, .�
Phone. No.: tf b _531 w `�r7 L
Signature:
Date:
The following signature block is o y to be used when the box for conditional approval in III D above has been checked.
I (we) certify that I (we) have comm#ted to purchase the animal waste application and handling equipment as specified in my
(our) waste management plan and WM submit to DEM a verification of delivery and installation from a Technical Specialist
within 15 calendar days following the date specified in the conditional certification. I (we) realize that failure to submit this
verification is a violation of the waste management plan and will subject me (us) to an enforcement action from DEM.
Name of -Land Owner:
Signature: Date:
Name of Manager(if different from owner):
Signature: Date:
E) Odor Control Insect Control and Mortality Mana ement SD SI WUP RC orI
Methods to control odors and insects as specified in the Plan have been installed and are operational. The mortality
management system as specified in the Plan has also been installed and is operational.
Name of Technical Specialist (Please Print) :
Affiliation: Date Work Completed:
Address (Agency)
ACZ R V
,,
hone No.:
Signature: Date:
•
AWC -- August 1, l9gr Z

Nutrient Management Plan For Animal Waste Utilization
06-21-2002
This plan has been prepared for:
Marshall Horne 500 Sow Farm
Marshall Horne
2595 Lamb Road
Garlwmt NC 28441
910-529-9281
This plan has been developed by:
Matthew Barefoot
Sampson SWCD
84 County Complex Road
Clinton, NC 28328
910-5 2-7963 Ext. 3
Loper SignatGe
Type of Plan: Nitrogen Only with Manure Only
Owner/Manager/Producer Agreement
I (we) understand and agree to the specifications and the operation and maintenance
procedures established in this nutrient management plan which includes an animal waste
utilization plan for the farm named above. I have read and understand the Required
Specifications concerning animal waste management that are included with this plan.
MME01"y/
Signature (owner)
Signature (manager or producer)
Date
Date
This plan meets the minimum standards and specifications of the U.S. Department of
Agriculture - Natural Resources Conservation Service or the standard of practices adopted
by the Soil and Water Conservation Commission.
Plan Approved By:
Specialist Signature
-7-3— oz
Date
------------------------------------------------------------- -----------------
764326 Database Version 2.0 Date Printed: 06-21-2002 Cover Page 1

Nutrients applied in accordance with this plan will be supplied from the
following source(s):
Commercial Fertilizer is not included in this plan.
S9
Swine Farrowing-Weanding Lagoon Liquid waste generated 1,601,500
gals/year by a 500 animal Swine Farrowing-Weanling Lagoon Liquid
operation. This production facility has waste storage capacities of
approximately 180 days.
Estimated Pounds of Plant Available Nitrogen Generated per Year
Broadcast
2473
Incorporated
4247
Injected
4677
Irrigated
2688
Actual PAN Applied
(Pounds)
Actual Volume Applied
(Gallons)
Volume Surplus/Deficit
(Gallons)
Year 1
3,409,00
1,979,027
-377,527
---- ------------------------------------------------------------------------------------------
Note: In source ID, S means standard source. U means user defined source.
764326 Database Version 2.0 Date Printed. 06-21-2002 Source Page 1 of 1

Waste Utilization Table
The Waste Utilization table shown on the following page(s) summarizes the waste utilization plan for this operation. This plan provides an estimate of the number of
acres of cropland needed to use the nutrients being produced. The plan requires consideration of the realistic yields of the crops to be grown, their nutrient
requirements, and proper timing of applications to maximize nutrient uptake.
This table provides an estimate of the amount of nitrogen required by the crop being grown and an estimate of the nitrogen amount being supplied by manure or other
by-products, commercial fertilizer and residual from previous crops. An estimate of the quantity of solid and liquid waste that will be applied on each field in order to
supply the indicated quantity of nitrogen from each source is also included.
A balance of the total manure produced and the total manure applied is included in the table to ensure that the plan adequately provides for the utilization of the
manure generated by the operation. Animal operations that generate liquid waste and utilize waste storage facilities (lagoons or holding ponds) may apply more or
less waste in any given year than is annually generated by the facility. In order to determine whether the plan adequately utilizes the waste produced by the facility,
the storage capacity table included in this plan should be reviewed to ensure that the design capacity of the storage facility is not exceeded during the planning period
Depending on the requirements of the crop and the nutrient content of the waste, some nutrients will likely be over or under applied if animal waste is beingutilized.
Waste should be analyzed before each application cycle and annual soil tests are required if animal waste is being applied. Soil tests should be used to balance the
nutrient application arrounts with the realistic yields of the crop to be grown. Nutrient management plans may require that the application of animal wastebe limited
so as to prevent over application of phosphorous when excessive levels of this nutrient are detected in a field
764326 Database Version 2.0 Date Printed: 06-21-2002 WUT Page 1 of 2

Waste Utilization Table
Year 1
Tract
Field
Source
I.D.
Soil Series
Total
Acre
Use,
Acres
Crop
RYE
RYE
Unit
Applic.
Period
Nitrogen
PA
Nutrient
Rea'd
Comm.
Fert.
Nutrient
Aaolied
Res.
Appiic.
Method
Manure
PA
Nutrient
Aoolied
Liquid
Manure
Applied
(acre)
Solid
Manure
Applied
(acre)
Liquid
Manure
Applied
(Field)
Solid
Manure
Applied
(Field)
(lbs1A)
N
(Ibs1A)
N
(lbs/A)
N
lbsIA
N
1000
ga11A
tons
1000 gals
tons
4481
ZONE
S9
Goldsboro
3.5
3.5
Small Grain Overseed
1.0
Tons
10I1-3131
50
0
0
Irrig.
50
14.9
0.0
52.1
0.0
4481
ZONE
S9
Goldsboro
3.5
3.5
Hybrid Betmudagrass
Ha
6.5
Tons
311-9130
296
0
0
Irrig.
296
176.4
6.0
617.3
0.0
4481
ZONE
S9
Autryville
7.01
7.0
Small Grain Overseed
1.0
r Tom
1011-3131
50
0
0
Irrig,
50
29.s
0.0
208.5
0,0
4481
ZONE
S9
Autryville
-J
T
7.0
Hybrid Bermudagrase
Hay
5.4
Eons
311-9130
264
0
0
Irrig.
264
157.3
0.0
1,101.1
0.0
Lagoon Liquids
Total Applied, 1000 gallons
1,979
Total Produced, 1000 gallons
1,602
Balance, 1000 gallons
•378
Manure Solids
Total Applied, tons
0
Total Produced, tons
0
Balance, tons
0
Notes: 1. In the tract column, symbol — means leased, otherwise, owned. 2. Symbol' means user entered data.
-- ----------------------------------------------------------------------------------------------------------------------------------------------------
764326 Database Version 2.0 Date Printed: 06-21-2002 WUT Page 2 of 2

The Irrigation Application Factors for each field in this plan are shown in the following table. Infiltration
rate varies with soils. If applying waste nutrients through an irrigation systerrt you must apply at a rate
that will not result in runoff. This table provides the mannuun application rate per hour that may be
applied to each field selected to receive wastewater. It also lists the maximum application amount that
each field may receive in any one application event.
Irrigation Application Factors
Trod
Field
Soil Series
Application Rate
(inch -A—)
Application Amok
(inches)
4491
ZONE 1
Goldsboro
0.50
0.96
4481
ZONE 2
Autryville
0.60
0.72
--------------------------------------------------- ----------
764326 Database Version 2.0 Date Printed: 06-21-2002 IAF Page 1 of I

The following Lagoon Sludge Nitrogen Utilization table provides an estimate of the number of acres needed for
sludge utilization for the indicated accumulation period. These estimates are based on average nitrogen
concentrations for each source, the number of animals in the facility and the plant available nitrogen application rates
shown in the second column_
Lagoon sludge omtains nutrients and organic natter remaining after treatment and application of the effluent. At
clean out, this material must be utilized for crop production and applied at agronomic rates. In rnost cases, the
priority nutrient is nitrogen but other nutrients including phosphorous, copper and zinc can also be limiting. Since
nutrient levels are generally very high, application of sludge must be carefully applied.
Sites must first be evaluated fortheir suitability for sludge application Ideally, effluent spray fields should not be
used for sludge application. If this is not possible, care should be taken not to load effluent application fields with
high almunts of copper and zinc so that additional effluent cannot be applied On sites vulnerable to surface water
moving to streams and lakes, phosphorous is a conceal. Sobs containing very high phosphorous levels may also be a
concern.
Lagoon Sludge Nitrogen Utilization Table
Crop
Maximum
PA-N Rate
lblac
Maximum Sludge
Application Rate
1000 gallac
Nlinimum Acres
5 Years Accumulation
Minimum Acres
10 Years Accumulation
Minimum Acres
15 Years Accumulation
Swine FarrowingWea111ing Lagoon Sludgc - Standard
Corn 120 bu
150
13.16
14.82
29.63
44.45
Hay 6 ton R.Y.E.
300
2632
7.41
14.92
22.22
Soybean 40 bu
160
14.04
13.89
27.78
41.67
-------------------------------------------------------------------------------- - ----- -
764326 Database Version 2.0 Date Printed: 06-21-2002 Sludge Page 1 of 1

The Available Waste Storage Capacity table provides an estimate of the number of days of storage
capacity available at the end of each month of the plan Available storage capacity is calwlated as the
design storage capacity in days minus the number of days of net storage volume accurntilated The start
date is a value entered by the user and is defined as the date prior to applying nutrients to the first crop in
the plan at which storage volurne in the lagoon or holding pond is equal to moo.
Available storage capacity should be greater than or equal to zero and less than or equal to the design
storage capacity of the facility. if the available storage capacity is greater than the design storage capacity,
this 'indicates that the plan calls for the application of nutrients that have not yet accumulated If available
storage capacity is negative, the estimated volume of accumulated waste exceeds the design storage volume
of the structure. Either of these situations indicates that the planned application interval in the waste
utilization plan is inconsistent with the structures temporary storage capacity.
Available Waste Storage Capacity
Source Name
Swine Farrowing-Weanling Lagoon Liquid
Design Storage Capacity (Days)
Start Date
1 9130
180
Plan Year
Month
Available Storage Capacity (Days)
i
1
107
1
2
93
1
3
147
1
4
180
1
5
180
1
6
180
1
7
180
1
8
180
1
9
180
1
10
159
1
11
139
1
12
113
* Available Storage Capacity is calculated as of the end of each month.
------------------------------------------------------------------ -
764326 Database Version 2.0 Date Printed: 06-21-2002 Capacity Page 1 of 1

Required Specifications For Animal Waste Management
1. Animal waste shall not reach surface waters of the state by runoff, drift,
manmade conveyances, direct application, or direct discharge during
operation or land application. Any discharge of waste that reaches surface
water is prohibited.
2. There must be documentation in the design folder that the producer either
owns or has an agreement for use of adequate land on which to properly
apply the waste. If the producer does not own adequate land to properly
dispose of the waste, he/she shall provide evidence of an agreement with a
landowner, who is within a reasonable proximity, allowing him/her the use
of the land for waste application. It is the responsibility of the owner of the
waste production facility to secure an update of the Nutrient Management
Plan when there is a change in the operation, increase in the number of
animals, method of application, receiving crop type, or available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs
for realistic crop yields based upon soil type, available moisture, historical
data, climatic conditions, and level of management, unless there are
regulations that restrict the rate of applications for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre per
year. Waste may be applied to land eroding at more than 5 tons per acre per
year but less than 10 tons per acre per year provided grass filter strips are
installed where runoff leaves the field (see USDA, NRCS Field Office
Technical Guide Standard 393 - Filter Strips).
5. Odors can be reduced by injecting the waste or by disldng after waste
application. Waste should not be applied when there is danger of drift from
the land application field.
6. When animal waste is to be applied on acres subject to flooding, waste will
be soil incorporated on conventionally tilled cropland. When waste is
applied to conservation tilled crops or grassland, the waste may be
broadcast provided the application does not occur during a season prone to
flooding (see "Weather and Climate in North Carolina" for guidance).
--------------------------------------------------------------------------------------------------
764326 Database Version 2.0 Date Printed: 06-21-2002 Specification Page 1 o.

7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate
such that runoff does not occur offsite or to surface waters and in a method
which does not cause drift from the site during application. No ponding
should occur in order to control odor and flies.
g- Animal waste shall not be applied to saturated soils, during rainfall events,
or when the soil surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner
that the crop is not covered with waste to a depth that would inhibit growth.
The potential for salt damage from animal waste should also be considered.
10. Nutrients from waste shall not be applied in fall or winter for spring planted
crops on soils with a high potential for leaching. Wastelnutrient loading
rates on these soils should be held to a minimum and a suitable winter cover
crop planted to take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with
the following: The outer perimeter of the land area onto which waste is
applied from a lagoon that is a component of a swine farm shall be at least
50 feet from any residential property boundary and canal. Animal waste,
other than swine waste from facilities sited on or after October 1, 1995, shall
not be applied closer that 25 feet to perennial waters.
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other
than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and public
right -of --ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or
wetlands by a discharge or by over -spraying Animal waste may be applied
to prior converted cropland provided the fields have been approved as a
land application site by a "technical specialist". Animal waste shall not be
applied on grassed waterways that discharge directly into water courses,
and on other grassed waterways, waste shall be applied at agronomic rates
in a manner that causes no runoff or drift from the site.
----------------------------------------------------------------------------- --
764326 Database Version 2.0 Date Printed: 06-21-2002 Specification Page 2 a

16. Domestic and industrial waste from washdown facilities, showers, toilets,
sinks, etc., shall not be discharged into the animal waste management
System.
17. A protective cover of appropriate vegetation will be established on all
disturbed areas (lagoon embankments, berms, pipe runs, etc.). Areas shall
be fenced, as necessary, to protect the vegetation. Vegetation such as trees,
shrubs, and other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible. Berms
and structures should be inspected regularly for evidence of erosion,
leakage, or discharge.
18. If animal production at the facility is to be suspended or terminated, the
owner is responsible for obtaining and implementing a "closure plan" which
will eliminate the possibility of an illegal discharge, pollution, and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected on
a regular basis to prevent breakdowns, leaks, and spills. A regular
maintenance checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other
crops for direct human consumption. However, if animal waste is used on
crops for direct human consumption, it should only be applied pre -plant
with no further applications of animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and bottom
elevations of the temporary storage (pumping volume) of all waste
treatment lagoons. Pumping shall be managed to maintain the liquid level
between the markers. A marker will be required to mark the maidmum
storage volume for waste storage ponds.
----- ------------------------------------_------------------------
764326 Database Version 2.0 Date Printed: 06-21-2002 Specification Page 3 o:

22. Waste shall be tested within 60 days of utilization and soil shall be tested at
least annually at crop sites where waste products are applied. Nitrogen
shall be the rate -determining nutrient, unless other restrictions require
waste to be applied based on other nutrients, resulting in a lower application
rate than a nitrogen based rate. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for
optimum crop production. Soil and waste analysis records shall be kept for
a minimum of five years. Poultry dry waste application records shall be
maintained for a minimum of three years. Waste application records for all
other waste shall be maintained for a minimum of five years.
23. Dead animals will be disposed of in a manner that meets North Carolina
regulations.
--------------------------------------------------------------------------------------
764326 Database Version 2.0 Date Printed: 06-21-2002 Specification Page 4 o

Crop Notes
The following crop note applies to field(s): ZONE 1
Bermudagrass Coastal Plain, Mineral Soil, Poorly Drained to Somewhat Poorly Drained.
Adaptation: Effective artificial drainage MUST be in place to achieve Realistic Yield Expectations
provided for these soils.
In the Coastal Plain, hybrid bermudagrass sprigs can be planted Mar. 1 to Mar. 31. Cover sprigs I" to 3"
deep (1.5" optimal). Sprigs should be planted quickly after digging and not allowed to dry in sun and wind.
For Coastal and Tifton 78 plant at least 10 bu/ac in 3' rows, spaced 2' to 3' in the row. Generally a rate of
30 bu/ac is satisfactory to produce foil groundcover in one or two years under good growing conditions.
Tifton 44 spreads slowly, so use at least 40 bu/ac in 1.5' to 2' rows spaced 1' to 1.5' in row. For
broadcast/disked-in sprigs use about 60 bu/ac. Soil test for the amounts of lime, phosphorus, potassium
and micronutrients to apply preplant and for annual maintenance. Apply 60 to 100 lb/ac N in the
establishment year in split applications in April and July. For established stands apply 180 to 240 lb/ac N
annually in split applications, usually in April and following the first and second hay cuts. Reduce N rates
by 25% for grazing. Refer to NCSU Technical Bulletin 305 Production and Utilization of Pastures and
Forages in North Carolina for more information or consult your regional agronomist or extension agent for
assistance.
The following crop note applies to field(s): ZONE 2
Bermudagrass Coastal Plain, Mineral Soil, Moderately Well Drained.
Adaptation: Well -adapted.
In the Coastal Plain, hybrid bermudagrass sprigs can be planted Mar. I to Mar. 31. Cover sprigs 1" to 3"
deep (1.5" optimal). Sprigs should be planted quickly after digging and not allowed to dry in sun and wind_
For Coastal and Tifton 78 plant at least 10 bu/ac in 3' rows, spaced 2' to 3' in the row. Generally a rate of
30 bu/ac is satisfactory to produce full groundcover in one or two years under good growing conditions.
Tifton 44 spreads slowly, so use at least 40 bu/ac in 1.5' to 2' rows spaced 1' to 1.5' in row. For
broadcasttdisked-in sprigs use about 60 bu/ac_ Soil test for the amounts of lime, phosphorus, potassium
and micronutrients to apply preplant and for annual maintenance. Apply 60 to 100 lb/ac N in the
establishment year in split applications in April and July. For established stands apply 180 to 240 lb/ac N
annually in split applications, usually in April and following the first and second hay cuts_ Reduce N rates
by 25% for grazing. Refer to NCSU Technical Bulletin 305 Production and Utilization of Pastures and
Forages in North Carolina for more information or consult your regional agronomist or extension agent for
assistance.
-------------------------------------------------------------------------------------- -- -
764326 Database Version 2.0 Date Printed: 06-21-2002 CropNote Page 1 of

The following crop note applies to field(s): ZONE 1
Small Grain: CP, Mineral Soil, low -leachable
In the Coastal Plain, oats and barley should be planted from October 15-October 30; and rye from October
15-November 20. For barley, plant 22 seed/drill row foot and increase the seeding rate by 5% for each
week seeding is delayed beyond the optimum time. See the seeding rates table for applicable seeding rate
modifications in the current NCSU "Small Grain Production Guide". Also, increase the initial seeding rate
by at least 10% when planting no -till. Oats should be planted at 2 bushels/acre and rye at 1-1 1/2
bushels/acre. Plant all these small grains at 1-1 1/2" deep. Adequate depth control is essential. Review the
NCSU Official Variety "green book" and information from private companies to select a high yielding
variety with the characteristics needed for your area and conditions. Apply no more than 30 lbs/acre N at
planting. Phosphorus and potash recommended by a soil test can also be applied at this time. The
remaining N should be applied during the months of February -March.
The following crop note applies to field(s): ZONE 2
Small Grain: CP, Mineral Soil, medium leachable
In the Coastal Plain, oats and barley should be planted from October 15-October 30; and rye from October
15-November 20. For barley, plant 22 seed/drill row foot and increase the seeding rate by 5% for each
week seeding is delayed beyond the optimum time. See the seeding rates table for applicable seeding rate
modifications in the current NCSU "Small Grain Production Guide". Also, increase the initial seeding rate
by at least 10% when planting no -till. Oats should be planted at 2 bushels/acre and rye at 1-1 1/2
bushelslacre. Plant all these small grains at 1-1 1/2" deep. Adequate depth control is essential. Review the
NCSU Official Variety "green book" and information from private companies to select a high yielding
variety with the characteristics needed for your area and conditions. Apply no more than 30 lbs/acre N at
planting. Phosphorus and potash recommended by a soil test can also be applied at this time. The
remaining N should be applied during the months of February -March.
-------------------------------------------------------------------------- ------ -
764326 Database Version 2.0 Date Printed: 06-21-2002 Crop Note Page 2 of

WASTE UTILIZATION PLAN AMENDMENT
This amendment is included to address the wastewater that may need to be pumped, for
maintenance purpose, from the abandoned Iagoon.
Lagoon_# _._. Surface Area
0.60 Acres
Rainfall in excess of evaporation during 12 month period in Sampson County = I I.23
inches (094 foot)(From Rainfall -Evaporation Chart for Area 3).
Volume of Rainfall to be Pumped From Abandoned Lagoon
I = 182,982.65 gallons
PAN from Waste Analysis Report for Abandoned Lagoon = 0.15 NI1000 gallons.
Total PAN from the abandoned lagoon that may need to be applied per year for
maintenance = 27.4 lbs N.
The PAN deficit from the existing waste utilization plan is (-721 Is N). The new deficit
is (-693.6 lbs N). Therefore, there is adequate land included in the existing waste
utilization plan to treat the wastewater pumped, for maintenance, from the abandoned
lagoon_
Xt I
;• ; DATE
-r 7_ q- oz
CHNICAL SPE iALIST DATE

JCDA
omic Division 4300 Reedy Creek Road Raleigh, NC 27607-6465 919 733-2655
ReportNo, W09497 W
6/18/02
Grower: Horne, Marshall
2595 Lamb Rd.
Garland, NC 28441
Waste Analysis Report Farm:
Sampson County
Copies To:
ample Info.
Laboratory Results (parts
per million unless otherwise noted)
ample 10:
N
P K Ca Mg
5
Fe Mn Zn
Cu B
Mo
Ct
C
Total 451
174 606 183 69.0
68,9
12.7 1.16 4.00
0.94 1,08
IN -N
Vaste Code:
-NH4
LS
-NO3
Na Ni Cd Pb
At
Se Li pH
SS C:N
DM%
CCE%
ACE K a!
205
7.09
1'escription:
OR-N
Mine Lagoon Liq,
Urea
-
!ecommendations:
Nutrients Available for First Crop
1150000 gallons
Other Elements
lbs✓1000
gallons
pplicatlon Method
N P205 K20 Ca Mg S Fe Mn
Zn Cu
B Mo Cl
Na Ni Cd
Pb
At
5e Li
Irrigation
1.9 2.3 4.9 1.1 0.40 0,40 0.07 0.01
0,03 0.01
0.01
1.7
Please be sure to fill out the waste analysis information sheet completely. We need to know the type of waste (waste codes are listed on back of the form), a brief description, and the
application
method(s) that you
intend to use (listed on lower right side of front). Thank you very much.
ample Info.
Laboratory Results (parts per million unless otherwise noted)
'ample 1D.•
N P K Ca --Mg
5
Fe Mn Zn
Cu B
Mo
Ct
C
Total 36.5 10.2 36.3 86.7 19.9
102
1.50 0,25 0,53
0.11 0.32
1N -N
Vaste Code:
-NH4
LS
•NO3 No Ni Cd Pb
Al
Se Li pH
55 C:N
DM%
CCE%
ALE K al
lescription.
OR-N 21.2
6,72
mine Lagoon Liq.
Urea
recommendations:
Nutrients Available for First Crop
1bs11000 gallons
Other Elements
lbs11000
allons
pplication Method
N P205 K20 Ca At S Fe Mn
Zn Cu
8 Mo Cl
Ne Ni Cd
Pb
At
Se Li
Irrigation
0.15 0,14 0.29 0.51 0.12 0.06 0.01 T
T T
T
0.18
The pH of the lagoon liquid is below the ideal range for bacterial action and waste treatment, Gradually adjust pH by adding
1 Ib, of agricultural lime per 10M cu, ft. of liquid remain�ng
in the lagoon Sample
the lagoor
monthly and continue to adjust
pH until it is within the desired range of 7.0-8.0.

pe� �jekv
e,
fie4 U�S�
EMERGENCY ACTIO � K'AN
1 1�P9
P TrERSDwQ 9��!
EMERGENCY MANAGEMENT SYSTEM
SwCD c
NRCS '1
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing, or running off site. You should not wait until wastes reach surface waters or
leave your property to consider that you have a problem_ You should make every effort to
ensure that this does not happen. This plan should be posted in an accessible location for
all employees at the facility. The following are some action items you should take.
1. Stop the release of wastes. Depending on the situation, this may or may not be
possible. Suggested responses to some possible problems are listed below.
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B: Runoff from waste application. field -actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that caused the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C: Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
D: Leakage from flush systems, houses, solid separators -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure no siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
December 18, 1996

e. Repair all leaks prior to restarting pumps.
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed to
flowing leaks- possible action:
a. Dig a small sump or ditch away from the embankment to catch all seepage,
put in a submersible pump, and pump back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon
bottom as soon as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what duration?
c. Any damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does.the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off of the property)?
h. How much reached surface waters?
3: Contact appropriate agencies.
a. During normal business hours, call your DWQ (Division of Water Quality)
regional office; Phone - - After hours, emergency number. 919-733-3942.
Your phone call should include: your name, facility, telephone number, the details
of the incident from item 2 above, the exact location of the facility, the location or
direction of movement of the spill, weather and wind conditions. The corrective
measures that have been under taken, and the seriousness of the situation.
b. If spill leaves property or enters surface waters, call local EMS Phone number -
c. Instruct EMS to contact local Health Department.
d. Contact CES, phone number - - , local SWCD office phone number
and local NRCS office for advice/technical assistance phone number - -
4: If none of the above works call 911 or the Sheriffs Department and explain your
problem to them and ask that person to contact the proper agencies for you.
5: Contact the contractor of your choice to begin repair of problem to minimize off -site
damage.
a_ Contractors Name: 5
b_ Contractors Address:E---`�`f'�
c. Contractors Phone:
2 December'] 8, 1996

6: Contact the technical specialist who certified the lagoon (NRCS, Consulting
EnEineer, etc.)
a. Name: ' A
b. Phone: 9 -
7: Implement procedures as advised by DWQ and technical assistance agencies to
rectify the damage, repair the system, and reassess the waste management plan to
keep problems with release of wastes from happening again.
3 December 18, 1996

0
Swine Farm Waste Management Odor Control Checklist
Source Cause �� SMPs to Minimize Odor Site Specific Practices
Farmstead Swine
Zr Vegetative or wooded buffers; •0
t Recommended best management practices;
Good judgment and common sense
Animal body surfaces + Dirty manure -covered animals ❑ Dry floors
Floor surfaces + Wet manure -covered floors AJ Slotted floors;
Waterers located over slotted floors;
Feeders at high end of solid floors; ,
,,M' Scrape manure buildup from floors;
Underfloor ventilation for drying
Manure collection pits + Urine; Rl Frequent manure removal by flush, pit recharge,
+ Partial microbial decomposition __�or.scrape;
I ,Underfloor ventilation
Ventilation exhaust fans e Volatile gases; M Fan maintenance;
Dust Efficient air movement
Indoor surfaces a Dust Washdown between groups of animals;
❑ Feed additives;
❑ Feeder covers;
10 Feed delivery downspout extenders to feeder
covers
Flush tanks + Agitation of recycled lagoon lush tank covers;
liquid while tanks are filling Extend fill lines to near bottom of tanks with
anti -siphon vents
Flush alleys + Agitation during wastewater �-Underfloor flush with underfloor ventilation
conveyance
Pit recharge points + Agitation of recycled lagoon Extend recharge lines to near bottom of pits
liquid while pits are filling with anti -siphon vents
Lift stations + Agitation during sump tank ❑ Sump tank covers
Filling and drawdown
Outside drain collection + Agitation dt
or junction boxes conveyance
AMOC - November 11, 1996, Page 3
wastewater .11 Box covers

Source Cause BMPs. to Minimize Oddr Site Specific Practices
End of drainpipes at
. Agitation during wastewater
Extend discharge point of pipes underneath
lagoon
conveyance
lagoon liquid level
Lagoon surfaces
• Volatile gas emissions;
Proper lagoon liquid capacity;
• Biological mixing;
Correct lagoon startup procedures; r
• Agitation
P- Minimum surface area -to -volume ratio,
agitation when.pumping;
Mechanical>inimurn
aeration;
❑ Proven biological additives -
Irrigation sprinkler
• Nigh pressure agitation;
Irrigate on dry days with little or no wind;
nozzles
. Wind drill
�mimum recommended operating pressure;
_
Pump intake near lagoon liquid surface;
❑ Pump from second -stage lagoon
Storage tank or basin • Partial microbial decomposition; ❑ Bottom or midlevel loading;
surface a Mixing while filling;
❑ Tank covers;
• Agitation when emptying ❑ Basin surface mats of solids;
❑ Proven biological additives or oxidants
Settling basin surface • Partial microbial decomposition; )3— Extend drainpipe outlets underneath liquid
• Mixing while filling; level;
• Agitation when emptying Ef-IRemove settled solids regularly
Manure, slurry or sludge • Agitation when spreading; ❑ Soil injection of slurry/sludges;
spreader outlets . Volatile gas emissions ❑ Wash residual manure from spreader after use;
❑ Proven biological additives or oxidants
Uncovered manure, • Volatile gas emissions while ❑ Soil injection of slurrylsludges
slurry or sludge on field drying ❑ Soil incorporation within 48 hrs.;
surfaces
❑ Spread in thin uniform layers for rapid drying;
❑ �Vven biological additives or oxidants
Dead animals • Carcass decomposition ,,U Proper disposition ofcarcasses
Dead animal disposal • Carcass decomposition ❑ Complete covering of carcasses in burial pits;
pits ❑ Proper locationlconslruction ol'disposal pits
Incinerators a Incomplete combustion ❑ Secondary stack burners
AMOC - November 11, 1996, Page 4

Source Cause lc—BMPs to Minimize Odor Site Specific Practices
Standing water around • Improper drainage; Grade and landscape such that water drains
facilities . Microbial decomposition of away Gom facilities
organic matter /
Manure tracked onto • Poorly maintained access roads Tartu access road maintenance
public roads from farm '
access
� � ■�IIIIfHO i li
Additional Information :
Available From
Swine Manure Management; 0200 Rule/BMP Packet
NCSU, County Extension Center
Swine Production Farm Potential Odor Sources and Remedies ; EBAE Fact Sheet
NCSU - BAE
Swine Production Facility Manure Management: Pit Recharge - Lagoon Treatment ; EBAE 128-88
NCSU - BAE
Swine Production Facility Manure Management: Underfloor Flush - Lagoon Treatment; EBAE 129-89
NCSU - BAE
Lagoon Design and Management for Livestock Manure Treatment and Storage; EBAE 103-83
NCSU - BAE
Calibration of Manure and Wastewater Application Equipment; EBAE Fact Sheet
NCSU - BAE
Controlling Odors from Swine Buildings; PIN-33
NCSU - Swine Extension
Environmental Assurance Program ; NPPC Manual
NC Pork Producers Assoc
Options for Managing Odor; a repots from the Swine Odor Task Force
NCSU Agri Communications
Nuisance Concerns in Animal Manure Management: Odors and Flies; PRO]07, 1995 Conference Proceedings
Florida Cooperative Extension
AMOC - November 11, 1996, Page 5

Insect Control Checklist for Animal Operations
Source
Cause
BMPs to Control Insects site Specific Practices
Liquid Systems
Flush Gutters
• Accumulation of solids
Flush system is designed and operated
sufficiently to remove accumulated solids from
tters as designed.
Remove bridging of accumulated solids at
dr�a ge -
Lagoons and Pits
•� Crusted Solids
Maintain lagoons, settling basins and pits where
pest breeding is apparent to minimize the
'�".
crusting of solids to a depth of no more than 6 - ,
$ i es over more than 30% of surface.
Excessive Vegetative
• Decaying vegetation
CY' Maintain vegetative control along banks of
Growth
lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along watees edge on impoundment's perimeter.
Dry Systems
Feeders
• Feed Spillage
Design, operate and maintain feed systems (e.g.,
` bunkers and troughs) to minimize the
a ulation of decaying wastage.
Clean up spillage on a routine basis (e.g., 7 - 10
day interval during summer; 15-30 day interval
_sWing winter).
Feed Storage
• Accumulations of feed residues
5 Reduce moisture accumulation within and
around immediate perimeter of feed storage
areas by insuring drainage away from site
and/or providing adequate containment (e.g.,
d bin far brewer's grain and similar high
re grain products).
Z
t for and remove or break up accumulated
solids in filter strips around feed storage as
needed.
AMIC - November 11, 1996, Page I

0,,
Source Cause BMPs to Control Insects- Site Specific Practices
Animal Holding Areas • Accumulations of animal wastes ,0 Eliminate low areas that trap moisture along
and feed wastage fences and other locations where waste
accumulates and disturbance by animals is
/ utimal.
,P] Maintain fence rows and filter strips around,
animal holding areas to minimize
accumulations of wastes (i.e., inspect for and
remove or break up accumulated solids as
Dry Manure Handling • Accumulations of animal wastes Remove spillage on a routine basis (e.g., 7 - 10
Systems day interval during summer; 15-30 day interval
during winter) where manure is loaded for land
application or disposal.
Irov,�ide for adequate drainage around manure
Kp11es.
Inspect for and remove or break up accumulated
wastes in filter strips around stockpiles and
manure handling areas as needed.
For more information contact the Cooperative Extension Service, Department of Entomology, Box 7613, North Carolina State University,
Raleigh, NC, 27695-7613.
AMIC - November 11, 1996, Page 2

- Ale e �c I t�
EMERGENCY ACTIONwl&
kC17yS��r�oN
PHONE NUMBERS 1999
DWQ 9/0 4n(.-lsy 1 N°h�sC
EMERGENCY MANAGEMENT SYSTEM'gs P
SWCD 5012 - fW 4
MRCS L- 'l
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing, or running off site. You should not wait until wastes reach surface waters or
leave your property to consider that you have a problem. You should make every effort to
ensure that this does not happen. This plan should be posted in an accessible location for
all employees at the facility. The following are some action items you should take.
1. Stop the release of wastes. Depending on the situation, this may or may not be
possible. Suggested responses to some possible problems are listed below.
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Cali a pumping contractor.
e. Make sure no surface water is entering lagoon.
B: Runoff from waste application. field -actions include:
a. immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that caused the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C: Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
D: Leakage from flush systems, houses, solid separators -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure no siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
December 18, 1996

e. Repair all leaks prior to restarting pumps.
E: Leakage from base or sidewall of lagoon. Often this is seepage as opposed to
flowing leaks- possible action:
a. Dig a small sump or ditch away from the embankment to catch all seepage,
put in a submersible pump, and pump back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon
bottom as soon as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what Auration?
c. Any damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off of the property)?
h. How much reached surface waters?
3: Contact appropriate agencies.
a. During normal business hours, call your DWQ (Division of Water Quality)
regional office; Phone - - After hours, emergency number. 9I9-733-3942.
Your phone call should include: your name, facility, telephone number, the details
of the incident from item 2 above, the exact location of the facility, the location or
direction of movement of the spill, weather and wind conditions. The corrective
measures that have been under taken, and the seriousness of the situation.
b. If spill leaves property or enters surface waters, call local EMS Phone number -
c. Instruct EMS to contact local Health Department.
d. Contact CES, phone number - - , local SWCD office phone number
and local NRCS office for advice/technical assistance phone number - -
4. If none of the above works call 911 or the Sheriff's Department and explain your
problem to them and ask that person to contact the proper agencies for you.
5: Contact the contractor of your choice to begin repair of problem to minimize off -site
damage.
a. Contractors Name:
b. Contractors Address:
c_ Contractors Phone:
2 December'] 8, 1996

6: Contact the technical specialist who certified the lagoon (NRCS, Consulting
Engineer, etc.)
a. Name: ' .
b_ Phone: 9 /
7: Implement procedures as advised by DWQ and technical assistance agencies to
rectify the damage, repair the system, and reassess the waste management plan to
keep problems with release of wastes from happening again.
3 December 18, 1996

Swine Farm Waste Management Odor Control Checklist
Source Cause / HMPs to Minimize Odor Site Specific Practices
stead
ine production /Vegetative or wooded buffers; a
r Recommended best management practices;
Good judgment and common sense
Animal body surfaces • Dirty manure -covered animals O Dry floors
Floor surfaces • Wet manure -covered floors AJ Slotted floors;
Waterers located over slotted floors;
Feeders at high end of solid floors;
)3 ' Scrape manure buildup from floors;
Underfloor ventilation for drying
Manure collection pits • Urine; ,0 Frequent manure removal by flush, pit recharge,
• Partial microbial decomposition �or.scrape;
,e Underfloor ventilation
Ventilation exhaust fans • Volatile gases; /0 Fan maintenance;
Dust Efficient air movement
Indoor surfaces • Dust Washdown between groups of animals;
CJ Feed additives;
O Feeder covers;
_0 Feed delivery downspout extenders to feeder
covers
Flush tanks • Agitation of recycled lagoon Flush tank covers;
liquid while tanks are filling Extend fill lines to near bottom of tanks with
anti -siphon vents
Flush alleys • Agitation during wastewater
conveyance
flush with underfloor ventilation
Nit recharge points • Agitation of recycled lagoon Extend recharge lines to near bottom of pits
liquid while pits are filling evwith anti -siphon vents
Lift stations • Agitation during sump tank D Sump tank covers
filling and drawdown 'I-,'
Outside drain collection • Agitation during wastewater /0 Box covers
or junction boxes conveyance
AMOC - November 11, 1996, Page 3

Source Cause BNlP2 to Minimize Odor Site Specific Practices
End of drainpipes at • Agitation during wastewater Extend discharge point of pipes underneath
lagoon conveyance lagoon liquid level
Lagoon surfaces • Volatile gas emissions; Proper lagoon liquid capacity;
• Biological mixing; Correct lagoon startup procedures; r
•
Agitation
Minimum surface area -to -volume ratio;
inimum agitation when,pumping;
aeration;
mechanical aeration;
❑ Proven biological additives
Irrigation sprinkler
•
High pressure agitation;
Irrigate on dry days with little or no wind;
P nouies
a
Wind drift
t�lGlinimum recommended operating pressure;
Pump intake near lagoon liquid surface;
❑ Pump from second -stage lagoon
Storage tank or basin
•
Partial microbial decomposition;
❑ Bottom or midlevel loading;
surface
•
Mixing while filling;
❑ Tank covers;
•
Agitation when emptying
❑ Basin surface mats of solids;
❑ Proven biological additives or oxidants
Settling basin surface
•
Partial microbial decomposition;
Extend drainpipe outlets underneath liquid
•
Mixing while filling;
I vcl;
•
Agitation when emptying
emove settled solids regularly
Manure, slurry or sludge
•
Agitation when spreading;
❑ Soil injection of slurry/sludges;
spreader outlets
.
Volatile gas emissions
❑ Wash residual manure from spreader after use;
❑ Proven biological additives or oxidants
Uncovered manure,
•
Volatile gas emissions while
❑ Soil injection of slurry/sludges
slurry or sludge on field
drying
❑ Soil incorporation within 48 hrs.;
surfaces
❑ Spread in thin uniform layers for rapid drying;
❑ P�ven biological additives or oxidants
Dead animals • Carcass decomposition Proper disposition of carcasses
Dead animal disposal • Carcass decomposition ❑ Complete covering of carcasses in burial pits;
pits ❑ Proper local ion/const ruct ion of disposal pits
Incinerators • Incomplete combustion ❑ Secondary stack burners
AMOC - November 11, 1996, Page 4

Source Cause BMPs to Minimize Odor Site Specific Practices
water around a Improper
facilities . Microbial decomposition of
organic matter
Grade and landscape such that water drains
away from facilities
Manure tracked onto • Poorly maintained access roads 10 Farm access road maintenance
public roads from farm
access
Additional Information :
Available From :
Swine Manure Management, 0200 Rule/BMP Packet
NCSU, County Extension Center
Swine Production Farm Potential Odor Sources and Remedies; EBAE Fact Sheet
NCSU - BAE
Swine Production Facility Manure Management: Pit Recharge - Lagoon Treatment; EBAE 128-88
NCSU - BAE
Swine Production Facility Manure Management: Underfloor Flush - Lagoon Treatment, EBAE 129-88
NCSU-BAE
Lagoon Design and Management for Livestock Manure Treatment and Storage; EBAE 103-83
NCSU-BAE
Calibration of Manure and Wastewater Application Equipment ; EBAE Fact Sheet
NCSU-BAE
Controlling Odors from Swine Buildings ; PIH-33
NCSU - Swine Extension
Environmental Assurance Program ; NPPC Manual
NC Pork Producers Assoc
Options for Managing Odor; a report from the Swine Odor Task Force
NCSU Agri Communications
Nuisance Concerns in Animal Manure Management: Odors and Flies; PRO107, 1995 Conference Proceedings
Florida Cooperative Extension
AMOC - November 11, 1996, Page 5

Insect Control Checklist for Animal Operations
Source Cause BMPs to Control Insects Site Spec iBe Practices
Liquid Systems
Flush Gutters + Accumulation of solids Flush system is designed and operated
sufficiently to remove accumulated solids from
Rtiers as designed.
emove bridging of accumulated solids at
_ dts arge
Lagoons and Pits • Crusted Solids Maintain lagoons, settling basins and pits where
pest breeding is apparent to minimize the
crusting of solids to a depth of no more than 6 - ,
8_)t�es over more than 30% of surface.
Excessive Vegetative • Decaying vegetation C3," Maintain vegetative control along banks of
Growth lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along water's edge on impoundment's perimeter,
tems
Feeders • Feed Spillage lCf Design, operate and maintain feed systems (e.g.,
bunkers and troughs) to minimize the
esett�ulation of decaying wastage.
Clean up spillage on a routine basis (e.g., 7 - 10
day interval during summer; 15-30 day interval
wrine winter).
Storage Accumulations of feed residues ,01 Reduce moisture accumulation within and
around immediate perimeter of feed storage
areas by insuring drainage away from site
and/or providing adequate containment (e.g.,
cov$red bin for brewers grain and similar high
oisture grain products).
Inspect for and remove or break up accumulated
solids in filter strips around feed storage as
needed.
AMIC - November 11, 1996, Page I

Source Cause BMPs to Control Insects. Site Specific Practices
Animal Holding Areas • Accumulations of animal wastes ,0 Eliminate low areas that trap moisture along
and feed wastage fences and other locations where waste
accumulates and disturbance by animals is
,Mmural.
aintain fence rows and fitter strips around,
animal holding areas to minimize
accumulations of wastes (i.e., inspect for and ;
remove or break up accumulated solids as
Dry Manure Handling • Accumulations of animal wastes .0' Remove spillage on a routine basis (e.g., 7 - 10
Systems day interval during summer; 15-30 day interval
during winter) where manure is loaded for land
application or disposal. ,
Provide for adequate drainage around manure
piles.
Inct for and remove or break up accumulated
mwases in filter strips around stockpiles and
manure handling areas as needed.
For more information contact the Cooperative Extension Service, Dcpartment of Entomology, Box 7613, North Carolina State University,
Raleigh, NC, 27695-7613.
AM IC - November 11, 1996, Page 2

SAMPSON COUNTY
mat-Sh'aL ,(onset
LAGOON DESIGN
CONTENTS
FORMS
Conservation Plan Hap, NC-0ONS-5
Waste Management Plan
Animal Waste Management Worksheet
Design for Disposal Area
Plan for Excavated Pond, NC-ENG-14
Estimate for Embankment
Estimate of Excavation, ENC-523A
Topographical Map and Profiles, ENGr315A
Soils Investigations, SCS-ENGr538
Job Class
Designed by
Approved by
DAT E
Date to-+-SQ
Dat a
OF SHEETS
r
3
t
I
I
3
V

4
Q NC-CONS-5 CONSERVATION PLAN MAP
1-71
N• Approx. Scale 1" = 660.4
Prepared By
UNITED STATES DEPARTMENT OF AGRICULTURE SOIL CONSERVATION SERVICE
Cooperating with , Sampson _. Soil and Water Conservation District
Owner Marshall Horne Operator Same
Acres ini County -- Sampson _State North Carolina Date Prepared 9�11/80
I
020A•5CiF0RT WORT14 T[Y. 1971

-� %syi
: '
t 15Jz, U-SDEPARTNE14T.OF AGiICULTUA
OCT4613ER SOIL: CO"SERVAT ION SERVI C
S -MAP OIL
�0
per A S
wner Marshall Horne 0 a or
6 r
County son`.
State Carolina
•
---,:,�. JIT 13201MDSoil surveyshiet(s)"or code nos:' APProXjVjfeSCale
!,. --
.S. D
ent'o gricultu Soil Conservation 1 -jl;�,. Prepared by epartm f A Conservation cooperating
" .. t%�- "e.", - -, . _ g
-�CiInie'rvatlIi 'Diiirki:
-
tr
with amnson
0
?
407-
jr, J30
Yl-
70
46
S,
%
ITMENT OF AGRICULTURE
NSERVATION SERVICE
DOPERATING WITH
TURAL EXPERIMENT STATION
APPROX. SCALE 4f = I MILE
116USA-SCS-FM WOM. TUIAS 1976
, 9-78
SOIL SURVEY FIEL
?SAMPSON COUNTY, No
ADVANCE COPY - SUBJEt
SURVEY maS MOT NEEN CO"WiLdD W
W^, ME C"—*CD ANO IRKAS

Dat e 9 12/80
ANIMAL WASTE MANAGEMENT WORKSHEEr
Marshall Horne
SAMPSON COUNTY
INTRODUCTION
Mr. Horne presently runs a small feeder pig operation. He plans to increase
his herd to a 525 sow feeder pig system. He will contract with Murphy Farms
and the pigs will be moved out at 10 weeks old and approximately 40 pounds.
His existing lagoon will serve at the flush or secondary lagoon.
SITE CONDITIONS
The site is located on sandy loam soil (Autryville) with some clay loam. The
nearest dwelling not owned by Mr..Horne is greater than 1000 feet away* The
site is located approximately 18001 north of SR 1135. The site location ap-
pears suitable.
PROPOSED PLAN
The system will consist of a two -stage lagoon, Effluent from the hog houses
will be flushed into the larger treatment lagoon. Anerobic activity will
take place here. Once the effluent reaches the relative elevation of 48.0
it will flow into the flush or secondary lagoon. Water will be pumped out
of this lagoon and used to flush the houses. This re -cycle two -stage lagoon
is a closed system except for periodic pump -out for land disposal of waste.
NOTE: An additional source of water will be required until the system is
functioning as designed. The lagoons will be excavated with a �2'_ : 1
slope. All dams or dikes will have a combined slope of 5:1 with a 12
loot minimum top width. The landowner will be responsible for obeying all
local, state, and national laws and securing necessary permits.
All disturbed areas to be planted in permanent vegetation. The following
grass will be planted: '
Pre❑-i,, a suitable seedbed. Stockpile topsoil durirli construction
and place it in a 2" - 41' layer over dam and slopes if at all possi-
b-.•. Apply lime at a rate of 100 lbs./1000 sq* ft. or 2 tons/acre.
Apply fertilizer (10-10-10) at a rate of 20 lbs./1000 sq* ft. or 1000
ibs.Iac. Seed with tall fescue (KY-31) at a rate of 1.5 lbs./1000 sq&
ft. or 50 lbs./ac. Run a cultipacker or other suitable equipment over
area to place seeds into ground. Seeding dates are February - March
and Septimber - October.
Establish in coastal or common bermudagrass. Sprigs may be broadcast
onto a suitable seedbed. Spproximat ely 50 bushels of sprigs is recom-
mended per acre. Disk in sprigs and use a cultipacker or other suit -
;able equipment to firm the soil after planting. Apply lime at a rate
o, ),} lbs./1000 sq. ft, or 1.5 tons per acre. Apply fertilizer
or 10-10-10) at a rate of 10 lbs./ 1000 sq, ft. or 500 lbs.
per arse. Apply additional nitrogen as needed.

The maximum and minimum design levels for the flush or secondary lagoon
are as follows:
MAXIMUM DES ION LEVEL
= Rel.it ive Elevation (,
= Itivirt of Pipe Discharging
ii,to the Flush Lagoon
MINIMUM bESICN LEVEL
= Relative Elevation 40.0
_ �..7 Feet Below Discharge
Pipe
Disposal by land application is to be. started before the fluid level in the
flush or secondary lagoon reaches the maximum design level. Removal of the
effluent is to be stopped at or above the minimum design level. It is re-
commended that effluent be pumped from the flush (secondary) lagoon both
for flushing and land disposal. 'these lagoons are designed for waste treat-
ment .
OPERATION AND MAIN'rENANCE PLAN
1. Keep vegetation on embankinent and areas adjacent to the lagoon mowed.
7. Repair eroded areas and vegetate.
3. Apply. lime and fertilizer annuaI'ly or as needed.
4. It is strongly recommended that the treatment lagoon be precharged to
one-half of its capacity to prevent excessive odors during startup.
Precf.?rgiaig reduces the concentration of the initial wastes entering
the lagoon thereby reducing odors.

ANIMAL WASTE MANAGEMENT WORKSHEET
FIELD OFFICE Samnqon CoUnty DATE 9/12/80
Name Marshall Horne
Address Roiate 1. Garland, N. C._ PH.
Location On north side of SR 1135 approximately mile east of US 701.
PROJECT DESIGN DATA
Type Operation 525 Sows x 350 lbs. _ 1832750 lbs."
r soars x 350 lbs. = t82400 lips. -
'Pigs x 150 lbs. = lbs.
2280 Pigs x 4,9 lbs. = 68,400 lbs.
Total lbs. _ -260,550r -
Type House(s)
Flush X
Pit Pit Dimensions x x
Num'ec.r of Houses 1
Dimensior of Houses 4701 Iona
Excess Rainfall 5"
25 Year SEorm 7" ,
Estimated Size of lagoon _ 60t x 47O1 r
Estimated Waste Generation 8.4 lb./100 lb. hog/day
Method of Applying Effluent to Land—_Rongrdagon or irrigation
Times t:o be Emptied Per Year

DESIGN FOR TREATMENT LAGOON
For anerobic treatment, figure 1 lb. hog = 1 cu. ft. of storage for waste
treatment.
1. - lbs. Hogs/Year = 260,550 cu. ft. of storage
2. Planned Capacity: See ENG-523A for capacity f
x x W/ SS .264,958. cu. ft.
Length Width Depth
DESIGN FOR FLUSH LAGOON (The existing 401 x 2401 x IN W/ 11:1 SS will be used.)
3. Waste Generation:
8.4 lbs./day/100 lbs. x 260,550 lbs. x 365 days = 128,020 cu. ft.
62.4 lbs./cu. ft.
4. Excess rainfall for waste treatment lagoon:
5" (.42) if 149100 _ 5,922E cu. ft./
Wvgtv+�-
5. Excess rainfall for flush lagoon:
51' i .42) 240 x 40 - 4,032 �! Cu. ft.
Lengr h width
6. fU00 cwpaC Uy needed (add k 3, 4, a- '.. 5 ) 137 974 - cu. ft.
7. 01viae 4 c by 2 (\wpoor of times to bo emptied per year):
5.8.,987_.-_. CU- L t
!S. PlAoned n l: act; j
7&n x �n - x W/ S = 69,133 l� cu. ft.
Length Width Depth
9. Stora c renj fired for 25 year storm in treatm,Alt lagoon:
t4m10(i _ = _ 8,178iL cu. ft.
1 Kora e for 25 year storm _tn flush lagoon:
71, (- ) x 40 = 5,568 cu. ft.
Length Width

(2)
11. Total storm storage required:
(To be stored in flush lagoon) -- _ 13,746 = cu. ft.
12. Storage capacity in flush lagoon:
240 x 40 x 1,5 — 14,400 cu. ft. ✓
Average Length Average Width Depth
13. Add one (1) foot of freeboard to storm storage for a total of 2.5 ft.--
of dam (dike) above planned fluid level in flush lagoon.

r
DESIGN FOR DISPOSAL AREA
Marshall Horne LAGOON
Date September 12, 1980
1. Nitrogen Produced = 260;550 lbs. x 0.048/100 lb./day x 365 days
Nitrogen Produced — .45,64& lbs.
2. Figure 75% N. loss due to evaporation and volatization. It is anticipated
that the flush operation with recycled treated effluent will expose Nitro-
gen to the atmosphere and result in N. loss.
45J,48 . _ lbs. x 25% _ 111,412 y lbs.
3. Figure applying 600 lbs. N./Acre of Coastal Bermuda/Year.
! 11,41.,Z lbs. = 19 Acres Needed r
bOO lb./Acre
OR
11 -417 -_ lbs. = 57 Acres Needed
200 1b./Acre
V'

U. S. Department of Agriculture NC-ENG-14
Soil Conservation Service 8/72
File Code ENG-11
PLAN OF `rRrATMeI%W L+"0+4
SCD
Name MfsASKALL "OCKM No. REAP P ✓ Date 9 -1z -so
Req.
_ LENGTH
SIDE SLOPE:&TO 1
X.
9 � �
1� c , 4-g.o AVE. TOP ELEV. (FL01b)
of
ti
.,..---YID SECTION
/ a
I r 4 3$--L
O AVE. BOTTOM ELEV. I
/ Izz
LENGTH
r-
Volume cu. yds. Acre ft. Pond Use
_12' berm with less than 6' spoil height sloped away from pond
1' berm with less than 3' spoil height uniformly spread & sloped away from pond
Volume in depth C(area of top) + (area of bottom) + (4 s area midsection
cu yds. 6
27 7/.
Surface Area acres (If more Location Sketch`
than 0.25 ac. "Impounding Permit"
is required)
Volume REAP Cost Sharing
cu. yds.
Soil Type AvraYuILL e
B.M. Description NAIL @ 6"U-u L6*Et<
ity pavicit ►7ctC it iptoLuSizaa-mea L.ocw-r�
E Kk5T104G l6& N005F.
AssaMrzt> Elev. Sa•oo
Distribution:
1 copy landuser
1 copy plan folder

NC-ENG-12
8 /72
(formerly NC-71)
U.S. Department of Agriculture
Soil Conservation Service
VOLUME ESTIMATE FOR EARTH EMBANKMENT
Name JV 0AYA14[L
Address
Embankment: Top Width /7- Side Slope's
FILL
STATION HEIGHT
( Feet)
END AREA
(Sq. Ft.)
SUM OF
END AREAS
(Sq. Ft.)
DISTANCE
( Feet)
DOUBLE
VOLUME
(Cu. Ft. )
f-o D Q•
O
00
2zap
e 1 4-
�z
zip .2.-Z
3 9
93
joo
9300
13`9
)ao
13 9a4
Boa 3.9
SS
.1 0 7
`7 0
14 4-5 0
4 Q s. Q
1 z;L
2 5 -7
it, 880
St /� 4-3
)15
!� 5
!6 d
1(0,50eb
73.2-
64
}7.5
�0 o
IZ,Soo
S
teo
SS e�
-a,4•aa
/G Flo A•
O
1. Double Volume of Fill = 2 = (P Z gS Cu. Ft.
2. Volume of embankment fill ( line 1 = 27)= XL3-.-2— Cu. Yds.
3. Allowance for settlement (5 or 10% of line 2) = 7.3 �- Cu. Yds.
4. Total cubic yards (line 2 + line 3)= 2SS -- Cu. Yds.
fd -}I-
Computed by pate 3

- - - -A l-C _- /L1/f�PSf�i9LC �a,PNE LA600n/
fi Ho 6.5or/-
ES7-/Mq7-) of EXCAV47-10N FMBAniK/�iFw7� �._
- - --- - -- - - - - - - -- -- - - -- -- - — - ---- ;
VEQA�E' --C !UT
REAolmc 7-Al F
voLuM€' L'4�rJGvTfIT%O�y/S Bi4,SE.d UPAn! /O.O C�Ui` /,C//GL .- UGC _
CAE U.S�� • _
4XCAVA7-/01Y 9S13 Cam. � J5
E' 1V B.4MKMEn4T- C= Cu• �J S

ril
•J,
t9
it
S•I
QE
i al
Ix
I
.4
It
IR
L4
�
W
I
�
r4
NJ
I
t�c

�---_.. ter-- z• :�.
-- - US>_- _.RtG�,7'_ _TR,ANGF_ Egc.)ATronm AND
A= Ix5 -
A _
1A 3So x 44S = l//� 256
S ECT,o►.i (D TRtA.%t6L.E W iT)4 60' BAsa AND 4-7o' L`9
EKD AREA r-za- boo, Top lb' 13--WoMl
10' DEEP
i
,
A + zd7-
A- Lo) (to) + 2.5� fao)
A T 160 -+ 25 a
A = 3 Sa s� 44.
A
a�
Srn• END A�tdAa
DauBCE �'.,4.
1�/STi+IMCE
C'�U• �T•
350
445
i55, 75�
4 5 o
f'
z
—f-785 C41
TOTAL CAPXC-ITY rjsc�ICK
(b `�5, S33
5 Ec-rl t.m
© I I I, z5 a
` ecn6K
7-Tj a7S
.Z.4 c35 S
TbTAarL L' A 0 PX- t'r y E g J I R E
Z(p0 , S s 0 CA.-- •#
n `
-

• SCS-ENG-SM' U. S. DEPARTMENT OF AGRICULTURE
Aar• 5-70 SOIL CONSERVATION SERVICE
' SOIL INVESTIGATION TO DETERMINE SUITABILITY OF PROPOSED POND SITE
f
IBM, • • ••imp WKWITI-9
WATERSHM AREA KEASUREMEM
CROPLAND—
WOODLAND —ACRES •• • •' • •
SKETCH OF PROPOSED POND SHOWING WHERE BOR1NGS WERE MADE (Appro- scale I"= feet)
soon
■��■■■■■■
■■■■■■■■■■■■■
■w's■■■■r.0
W—wo
=,u■■■■■■■00
■■■
■■■■■■■■■■■■■■r..■■■■,
■■■■■■■■H■■■
■■■■c■■■■■■■■
■■■■■■■■■■■■
■■■■■■■■■■■■■
■■■■■■�■■■■■■■■■■■■■■■■■■■'
■■■■■■■
■■■
■■■■■■■■■■■■■■
BORING NUMBER AND PROFILE
Make �d list dam -site and spillway boringi ftrst- M@n panded ared and 6orrow pit barinr red andL
(Continued on back wheiv naccssarW SAow water tabie, ciewtions on dayn-site borings.
©�©f©10!©I�i�lE1
�Iml®1DI©iml®!mIE�ImImIDi®IF�1�7
�®I®I■I■1■I■I■I■■{■{■I■1■!t{■I■1■I■I■{■{■{■1■
®®�®1■1■l■I■�■I
■1■i■I■1■i■I■I■I■I■I■I■i■1■I■
®�'�I■1■1■!■!■l�,■1■!■!■1■1■I■1■I■1■1■I■!■1■1■
�®i■I■
1■i■i■1■'■I■I■1■1■i■I■1■I■l■i■I■I■I■1■
�ml�l■'�
1�LI�!■I■■i■I■1■1■!■I■1■I■!■'■I■!■1■I■
�■■1■!■i
!■1■■I■I■I■I■I■1■!■I■I■!■I■I■I■I■
MENOMONEE0
1
!
!
1■1■1
1■!■l
l■1■1■
■!■I■I■I■�■!■l■1■!■I■I■I■I■1■�■1■!■I■I■

TYPICAL VIEW OF A TWO -STAGE LAGOON SYSTEM
�'/2- i op Width I x-
1
_._Fluid Elevation 4-6'c
S S 2 Y2_ ; ti
Bottom Elevation 38.0
MAR51+rs�c. (-16�tn
SA�vsoK C,o,
Pipe Settled Top Elevation
i?mexgerrcy�9 g i-�iway-M-eva c
i
7,r,._ __ _ Fluid Elevation
;:
2 %, : i
Depth = i o SECONDARY LAGOON
(FLUSH)
F-xti
TREATMENT LAGOON Depth =
11
Bottom Elevation

Q f0
(U C7
CD
°11
ZF �V
C 'n W)
1
nl 111 • . r•
,
{-
till
k"tr
4.1
us (�!
im,
4i cll �— [ CJ •i, C7 '� it)
S_
J �-
�U ili n)
f3
v
C: (It-
VI
lJ >
Ali
J,
LI US1 L) .G rt1
S
rs•-u
C]
.jri
Z7
r) In .) AMC E- IV
J•'1:_47
to00
aJ
l)
till
iu1,�_ 4},fU
' rV
lV,
11, C:
1.
(Li
..• �- N
L1J
nl
C�' rt1 .�.' .1_ l) M
cc
a-
r"
aJ
Crll :; rVin tll
f_ Ii1 Itl
(1)
�, n
. i
rJl L)
C) rlJ { All 61,
ii 1}1
`�1
Ij
- O
m ril
it-C'
iV E� v
nl ~'
�)
WE'
;(� R. I" `•- n)"aka
(11 ti tl >•
.N
A)Cl-{�
A- ,.r on (V i 111
l!1
•rl1
fu
O
ll�
(�
11 t]
tl .-
•CJ (' Ll
E
+�
-L7 (It<u
,,, C� qi `t.l ,n w U rL
1�1
C) `11 ri
r,1 ..
cif
r>I)'..
•�) �1. •:>
'fit
�v (Il
,1i
r3 t�
rl� ui1 i� ,tJ' n' q
os .tv
�t4
(= E_
,.. l] �. ,-, Iw: {-' r11 hq N I-
•;.' CI � �
Li C3
L"1
li (j • ' q) V ,all_ ftl —"
- .fl C) [i
E-
V C)
:ntit,`l:
�. C
is ur)"L7 n' (U Ill
N •,`=
Iti
�7
c-,
C
rCl..
'[U
E' iU
•C)
: rl l C) n7
lU
tV iu
s
C)
NA,r,J
,
- U u,
1—
66
L:
All
U
iil (Ii C) O e f)fit
U
ail w 'CI CI
G Cl
c
~
rU . C)
> C (1) (d
. C) its
�,
'. {), R.
111
0 >
ci. C.1
O
II,
)•. LIl
t - Ali (11
tu
U-J C (V U
U
F a) (-i
Q l
I,, Q
N AD(11 O R
41
CL u)
-
♦.! .� {.. "N (l1
tj
`j
aili
a
a1 (h > f11 .3
All
N
C
3
> to -1) (U L' U
r� ail
no- IL- C 0 0.-{
AD
U/l-
lu :j lit)
�y o lu r7
III
A)
�..
> co
ltll"� .t1
C
C7
Isl f) ''' '
(1i I (1l
tv
Ill
1F-U ,[) w I.i t" }
ii if
711
L1.•In nl
/1 is >. iii,
v q 'iii (j ji
l
O
l 111
aI, 11() `- Lit �,�
0 �" 41) C) -- _f-
In
L: (11
L: —
j ltlt' U �:
t1/
111
ll
a
CJ
I u � ru
All
to
0 C. (1) -D 1!
.. �
c
'uG.
>. to
ni Q) I,1 iuit,
Ln
s� >I' u ) (7
Ql t^
i_
.� rtl
C7
.r U I<) '- C7-
L1_ C1 E.: _C) (At -In (1)
cy)
fj N (1)
"6 _I : U C:
W.
tU ItL
u,) rt�
4 r(1
N
II)
Q tiff
till IV
IU
(: ill
Ill
-L.1 rU
rU 'i1
'��
(u
_i?
All (If]
_,- J)
. _.
(U (U
7 n1
t1i)
rV
U �v tU
>.r_
c3 is
tiU ,`)
IrU -
v AI
r3 _7
f)
(1) rV _'y
an
( (_
N U
IV >• E
L• j
VI
Q rAN)C)
✓t)
vl
ii cu u
C)
aiIn
tv
-7
U(1
[
[)
UIT r+�
III qn Ill
11}
I-• 'u �
i� 'u'ii
0 (U q1
�U fU al

[)n } , a)
r bf)
L'h r, c .C. [A-r:r nl u, ( [s[) ru
L: L- C] CS iU ill) (tl ��� QI '� -} CL C .'i 41 0 >
C� Cl Id
�i v, ro r cf r cU +U `u Z} Un
;� 1- CJ cn El ] U Oil
f,] (� i}..rlti :;, tl i7 p L'1 �.._ v,
.r3.
C
nl `171 j, ba +' 1+.... L: >• c. �= ti f_ 0
nu J n ru r.: X D - qi
U, p r
} L_
> 'n f: U :�- W
r,f r r•: ,� y �.'•�. W rU u, .._ "t: I,rl bl)
u OF
>, l:
{? :3 CL Ci'-[) - .7 'u rrl
ru
rV O " . =] 1 -J . U "ll "vC'i �' fi" (U
Ill rtl �� of rU J,1 Lill qIrul fU (] 0 C t q) Ut h ql Er
�� cn h 3 S.- N rlJ r.: ;�',[7 vi _l= rn q n '� C. Q y� Q• ai
tj
i) 'i ^ (:: CJ ~,•(.] 1 rL cU ), L i- 17 n1 V rU �• E: l!
(. C� ,� ,n •-- fu RY ,t] 0U
ni �' :] +� �{ p {q t'U 'in
S.:
up , aJ ;I: C [! C) L) in v C, tU lJ U rU C'
ti i+ n.. r) - . CL U U
eJtl.', f" _r_ u' nn LJ t7 t] r. U C] U1 .. It 'O t) "- n -
y > rtl yr 0- (] rtl t'` u] � 3 al (] U C: +U in 0 :a
i' t
"• a, c C7 c N N] t r U- , D cU (I Cl y Z i rll ru N: U
U v lul O rV O Sj C7 U O rn N - N Cl. L` ' U
• . C; �,. ti" •(1 O rU •�^ 1 • rU rU b ,f~ 'U rn f7.
CS rll i. UG 41 f7 rll '- 2 a) O
tin h i �l !U ql IV U C) i ai l! �' �u v, In > ' . t = 7 ). rl1 C] 1
=, (� a _r) u [� rl of l UI U i fl. sv u� C]. L1 U ar �' C ,
U ' c) i, ;l. cZ N _ L n) uo :? n 1a :? Q _� �= E � .._ �� � 4J n tl0 ri
Ui ()'.. t N �1 1 ZI ) C- to tr7
rU .rJ nl =- nj r:l 's qj " qi ru C7 Cl r[1 _! 3 `- `' rU
U ;it nJ (.) �.) `U ri1 al C7 'n in v, UU C--
no �r( p -� u} rU N
# - C) ,✓ QJ 4 S "U ci. [ : L- cu .(' 7- (]. CL,� •Q bU R `
'c=S> W C ,n r� "L7 yr U b(r:= O E= V :. _ J~ �. of :]
tlr Sr +n ar :J U -] _ _ -, 1] bG N RI U In
vt .` ., y1 t-.,
✓s t- {] C l} 1U •.. „ C) Cl rtl i] t) t- L r[1 U UD.�
yr ;n i LU �? C) 1V N 0 i.� � Al (V �- �.) . Z � Ct) =7
L-. I7 w 01 vL ? u, +U •. _ �U N ,.. ,n 0
r tl , 0) bL1 Ij} VI
; rj a) C V [ v, rC} _ [IJ 1' (.)
C,Q _cC]' rtf > 0 qj 21 [- �.- e11 0114, (Z N '{' U C' (n�" aC..! Ila
r3 `_ rU 41 .[_ '� '� a n1 �. ra rll Lrrl`n, C� �} .; rU
rll I r'n �' 171 +Ci +U .,, nl lU ,, _C-: [.• r . _s:) ■. d) I. E -
nj 11 '1' .» �' '' . M Y l�U U -n� n) () •� `• C1
O qJ c` c .� vi n) IU
_� nl o �� Q, fj, 0 � a) �� ` ry C. F � 'ni a? n .i� 7
N I— ,n .. ._. L_ i.i u, nl Y L) `r F: (1 V �: E. N L�(l Cl
'U rnl C) JJ _ : ] (u u N E ,_ 0 +1) .- -x n)
�• ' � l_ Y 0 Ill 0 (. C 0
U!1 0L) tU C} u ; , r� Ul lJ titN F� {" Qi
Udl > OY ' ?- t : N -t -tj U OS in
rll N v, {•' , . �. _ Ll t- Cl C- (Z 11J u, ., �-
'r (1 +]1 •-
U L' e7 113 in ul .. �• CZ
cu
LUl
f D
r_
-! RJ ti -U
•�lY
U7
to
40
n! 1U Z) rU
i�
L tv
u .c
'U
Z] C) iV
Ul.�
3
O
0
tu)
Uri ` U 1U ).
u
U
'3
ry
,r
l
O
LJ
�- : ] L
N ti j
L:
�tj Cl C)
ru
un Cx L
Rr ru
qi
U
a�
dJ
Y a) (? p
till
CL
r� 1- n.� •--
,n n
Ill
v,
}� ru Up L
E" >
Q
6
N Wl w ql
bn r_ •— fi� r1
CJ N
L: •C kri
ru
[fl C] 1U
V

iiJ
tit)
lu
-,:} 0
• C
•'Cl
-
,...
;
0, Ill [-
11,
VI
ti!) C.
n,
UCl
y !-
to `n U1
l
In
rn
•
rll fJ
iIl
on •-
(.1. III )C
Il,
GO
4
Ln
n .._
UU
a1
n
.4
tit
,1!
._ lu aJ
u
fJl r
,c:
_q) ' J
qi
Qi i0
Li
it)
.�
t
1: its
'ill [U •''-
ID+
�7
(Ij(v
ri ) }:
iu{'
rr. ra
T;L
l;n _'
nl -�
(:)
_
L, �U
u, ._
�'
tli r•;
{� Ili
ill
•n �]
il)
N
C 1 t:
U fit rU
tZ3 E.
ru
-- ?.
[.
Y _a)
`
-
f" Il rTl ••-
LJ
w rt1
--
'c1
}= •�
• _._
''
It,
.0
c.
� ci
C).
CJ
tlr):- .,,
tr (v
o
nj j !_
Ft? :ll
(t,�
SL
f7. .{.r. •�
[U
} In
E,
,N �r
i��
��
,
_J uW
`1, III
LT • 1 1
[:
_ , � •-- •-
U .,,
Cl.---
C
ltl
c_ ril
[ .
tt z'
,
n, q1
• - (1) tic)
ti ©
Xj
t1 •-� ... gill _
Q1 :
al
rU . �-
`tl _-1 �..... i . (•}
.t
f-.
rL
U '.
I�
v
E�
, •1
J
{
u
ij
U
ql
'n
II}
•.
tit
V.
L
IM t,rl
!U ft1
�-
l:
t"
U
rV
A
C
nj
CIO
a1
(l
L-
V
Qi
`=1 ui
tCl
o _(u
-
E:
uu
III!
o,
n
of
Ill it)V-
.
UU 2
l
rU
-,_
..
hn
r, {]
1-
o
WI
ZI
CO
al As
ILI
Ij
,r, •n
(1'
.L oil
v�i�
L'
1�
ui
t1
•U1
41
Go
ILI
n
-lu
ru
tj
J-
E=
1
;u
"
vs •:�
Li C:
�, Ill
bn
- ui
�) %
f>
CIO
lot
Q
tj
CIP
ILI
—14
U
n
(_ 141 •.5
C7
�U l)
ru .t.
C�
CIO —
-

C
QY
u
t7 ,
U17
r„
- -ti
+a
, . A_:
'I•) 0
i : +U
CI[�
1 40'
n n1!
a.. _
r)
L
TS
Lj
b) O.-U.
• N
Al Cl� n)
L: ai uU
0 Ub a_
C7 -T7 0
hU..
C)l
IJ C: (u
0'
L}
tv uhh
a X ±.�1
:.1'L- i
tl1 C' n
41 !lt Ql
l ([, • N
W a-
0 2 tU
E•: -i,i
_C, �U
Uf7.�-• fil
u (u �u
C.. +u
U -0 tU
� >-�, .[,
_n — an
u 0 =�
L:
(U ^- n!
rU
n un� ra
-0 a_(D C: O
([t = nn =) o
00 7 •U :U
[_ y
n an--
n (1)
C) ? > [�
Un E '--
- CU a-
.o W 0 bn
T7 RU
CL in U ;n a -
a`) a! au 'U
C1 �j (V 3 C7
CL [U
_.) ._ U) N -U .
(Li
r
Vl L: (t1
L CA o
Q 0
�1 to Uu
+t1 Ui w (o C1
3 Ull `-
� � r 0 n
li,
u I. 0
nl - Iu
1 In •
as tv -L:1 u
a C C) Io +U
tJ U .3
N QJ.•- C1 ail
;u U t.) 'n.-0
U U ,[
IU t]
[- V in (U
fU I = (V v
U11
CL an U
:`7 a1 (v � •`n
in iV a1 Q -11.1
[-• I N.n
nnj aD -] L S
is t tj C I' l u
in n SlY
7 h1 to
Ci [_
Q l7 In M
go U
:;t u! Cl
:ice: i ` (v w
to >- > w
E'�t • --• 13 u,
N to it [. of
iii N tt)
v) J
-?Ewat
C) in 'L7 -i '
- q1
�rj [.. -C) Q3
to
Ut! i.: •i � ter
Q) r)
rvi U In:
it)
,.1
C) t3
t l
It (it
L= >,
_U OY t+f!
�= UI U .n
[Li t .. ,n -
? C) 7J SU U
UJ tC: tl)
ra
�L (U QY N
�� (u :
CC) ' C7
L a) �- U1
tu.� n(Y
too
C• •j -- L" E_
71 a..
11 L Ill a,
{� in
an a • �-•
(U
in �' ♦_ 0 ..�
tu! C) [ : —
cu _ lu
-� U tV }. �-
'-n,ai_7
C) (U (u L
on ri._ w ni
a-
Ut1 (U N _!
lu
!Li
VV t• E 7 CJ
_-_ QI m C' E' ail
±U
_ n U)
1�j ,u Cj y
E= CL .0 ul
RY 2
C) :c u a
nl
to •-• . !
qi
IJ' C7 .- C= 7
in f: WI O a-
-3 +t1 v — C' t-
� J C... n,
U C7 -10 Q. i-
d . U,
an Q1 -rn C
C1 V : �
qY U N
CL V+
r} a! o r!
[� +u _ n7 [-
.-.l _L7 In 'ti..l_ N
to Cl.- • 0. ' hn
L L) eV Cl' •ri
If an -0 a) n 0
0 L1 t7)ttY'()
IU1 40 n1 UI1
U1 "a.. tJ n) t41
4-1
UT7- T l)
`)n In O tv
iV Io a-'il ro
an UI `�i an
(U
L) it aY C) ty „i
an
] I U `� n!
'vi .;-: to UI In

`!;
,�.
E:
11,
((
( 111
..
I ,
•• •(.'
III
'V l 1
_n
.C: .n i.� C1_ (.,
!J
IJ' .� 'll
1[1 [:: f.l
�
- - -.
QI -•
-
[: 'eU �l1
v.�
_ s-- li= k- ._.
II!
• .
.
.t: -_ . _
`I'
1= (7 ...
Ill CY
Iu [" al
....l1
..
(; 14f -[- ....
-c]
[.)
. l} (ll
`•
('- 47
--•
E
CUtit 1
Ill
Ili i': '.:.
r]
tt) fit
�� -Cl
'u . : ,-;• 1��
('[.
C) UI) IlY
'rV
aU 1
tit I
t,rl
! ['- all
•[)
C) [..
(�
lit '�i,
at' i.
�, -
V _�
'I1 is
'' 1`il
•
C1 U!
Cl :�- ('}.
1' •-- L: t'= - r1+
LJ
QI
.��
[J :J O
1 '
k_
,.1
'- J '!.
•+'
1. -i)
IU kit
c r�J .n l) VU
,
-t'
l3
IU
i
0
nl IU
[It)tU Il)
V '1
_
1:'[1
(
[_
•t} _ -It
...; ..'
.1—
4, i:.rU ql.[?
-..1}
11( �� ..
U(f
'] -
•`] f 1
t�:f•):'
l]
`-- i1r'�
(.l l.J
u, is lU t: )• IU
. [r
'? C)
f!L t14' .(�
'i.
,n
•, _ 11)
jdl C' 1)
L,tI
), t.'
(� Ill `
" :: Ew
'h'U
VIJ
- fU
I.l.
n
[' l: ,..
�n tittU
IJ. 1!-
IU (1 ,
•-- l)
1 11 Ill
n1
111
L:
(, [:
(Lt
Il) .ty j
U)
•, tlJ lai
CS. CJ
f .VI tli
C)
rU titI
rU..i
�. In ,r�
,.. .C: v, ,.
,l, - l : •i- ,tl
- -
(1.
+
rj •-
-- + tit)
.1.) •.• C:
`r �-
a.
•LI ,I+ _���
It
li
rl:
IU (1 . ..
L U)
U
tll
,:I
";
r CJ ..
k,
1)' 'u
7
t C).
r.
I;
r!. , .,i Cl C.)
("J
<.)
�l) ,.
U
- lJ (.1
,n nl
[_ U)
��i `J J
l]
'i;, O •ili
•L-
Ul
rV L_
(7
(1 I]
_ .r)
a
l
I,I ;)� I L
U •-•
•- 11
,.' >-. -
'f`.I
f-]
to (� '
'� _O UJ
VtM 'to
N „ _ I J
.1) Cf t�
C.).,
;.,
IV
Im
n.
(.1- L: �-
CIO
•L1
IU
� -1
iq
:). )
., -'
I
„41)
i S_
-.j_
fu
(1
ILP
lu
'L'
;}
k';
�-,A
(•
k-
— S: OhICJ
`n
r,
It1 {,
•+
l'. IU ,•
Ily
tit) U
'�)
[tr)•.
' �J
'ii
•_.I1
•r
[] -J...
,ll iV .'
1) nj �.i IU
ttrl.l' f5j
:,I
L-
_.'
.."
_'r(i
lU rU
0
Ili'L]
r11
it) ._.
i.i q, •.
{ i„ t,l
N '- Ill
•,I (�
1.:
r 1.,
�'?'
IIJ ••
1•J
:,
fl) .1
_rU ..
U't7't:
C' "'
llli
't1 In ni
C C
N I_ In it
_(-
IlY
A (1 l
l 1
., ,n nl
r- -] (
ftf )
l7 1
tJ
v,
1'.
.._
ll1
aU�tl
1 lY
U19
. V.
V .n 1(1
tJ
LJ'---
I
1) IU
Id1 .
C: C)
•. � <•J •n IU �'1
(�
...
"L.1
Uh
(S 11,
.1 : C]
a-.
f:
1] -,n
11 [d1
U) N E- {1)
,tl ._.
L_ .t' �
IU
1-
+, ` ,
U _� (� Imo.
LJ ,!��
C)
1 U1
•LJ
lIQ
cl1 - (� �
I.:
,t1 t�
�
_47
c> tit)_
IZ.'r
L. -'
11J.f)
- (!) to (u
ill C' ;,
U) 11 • � al!
It, s
L1
41 .,.
—
C: Ic1
r)
, -
_C) ,U
'kCit
[.._ru
.t: --
'=.'1-'?
f_
:
- tenrJ-
�'C1�.')
U! fU [IIII
b�
41)V
'
lJ.
•;{v=})wl
-.Q.,
�,-}::
ril
IV_
(`
-U
[1 ! LItJC
[J
•(�;
11 IV
'_h11
.
L:
I:
[ JJ
Vo
•tv) L:
(fUv� ',.>,u}.
„�•__E�
tie"
t
rJllJ
U l}U.
.�� ,n
�• (_ Ul (-:
¢i ' l) <)
v �,
f:_ ' I .
Ir,
I` z) . —
ii
n =J Cf
�)
[-
(�--(]
._ (�
_)
.:_ Ill
n)
_c:
(] 7
Id
�Ll.
k-
f
+
_
Ll
_�' ru
�_ I\ .nl
•1, -1 ] .�-- "0
- 1 [' fit -
Tj
ca
1
ill (u
Q) L).
C) �� :� �' (_• ..
S]_
<'•I
1.1
�i
Ifl
\tI
r•.
t,il
1.1 ' [ '�
`: W) [.:
•vi'CJ i k-- •-• eU �:
[
C)
_] I
L
l: •' 411
r_ •i• In
-1 ri ,)1 :J c.� U) (:7
p
•L
:v
C7 [= ..
U,
-f} _}
(i ;.• '.l IU ,
by
ri
r)
c- (,f) tl 1-1
0 nJ

Y
rl
f11
M
- �'
(".•--
111
All
_1 Ili
rr
al
lu
I�d
u�5 �
ttl
u 1•�
( I
_
UI
I
i
I
1
•, Ill
I li
1
rift
11) I
JI
T7
1
1.
rill 1
I) !Jf! ��•
f11
•�:
r
117 `t,(1
in
+;
lJ f) .t_1 ,!r
{ .v; IU
C:
r".:
E: qJ
C1. illl
"U
C
.il ��� i_
t : `• •li
1..
�
•
1.1 .C�
!U rtf
RI ,U
t}U
I,}
> -1 1
:.i
rtl
Ito
✓I
L:f. t : �.
,1J rZ
rll
�1'
(1 tl,
�] fl, v_
_l t- Ian
.f- C.i
._.
r11
�'
f 1.
l) Ili
Itl
C. to %'
,.: is
ro
IU
:i, Ili-�J
•'
}�
-{
;1,
1. 41
ILIrtl
a i , :
(�
_}
E;
1, n, n,
�i
Qt
1
ILAll 4
1,
4F yU
.�:-.1U
_.J
Ih
Iu Iv
t
IU •I . rU E '
t� =1 •�.
...J 0'IJ U1

Q
� f=
i/ ECE r ` r1
n .
+ I L ` v
+.
1'
tj
NO •Vo
till 1� •—a v�' �' • +'1 ;l
r�. tilt nl U i 1rJ
tt1 1�•
.fJ
' u, { • till 'J
nJ ttJ F., cl
c] .v �' � el ail •��! 4• ai
It
141
LO
tl
it
I'' 3 41 rl :. •� � S: 1.4 i•E I'' '.' �i'i
nl U 'J . •rJ U .V ��1 IU
,iJ U41 '„'
till b1J V .1 t i-.
U ni
EN 1.t. I • n�
f,l i : r• ...
V

Wettable Acre Determination Information
$2:
€> . #`381
Original Evaluation
Central Office Process
.... c (Sti i i r p:ijT;
Notl€�cedioii Lieber §grit
k�tiieeirl� 15y/f�Ci6tp:
PehiW:Dde:
Regional Office Process
comments about Wettable Acres
:lagdSc+aro:l
_RhiLifi�aiii. .L'et. Sei>f:
1. . . . . ei. . bar a iltt
;vYk.itoii bay
Vlliotictensiari:i)iiedate
.WAIJ geh fieattoir F€crrif

EMERGENCY ACTION PLAN
PHONE . Tj,.,v S
DWQ 5��6—I
EMERGENCY SYSTEM
SWCD iV-s_i Z-75G
IN R ! � Z —?563
iris oian wi.ii be irnmemenced in the :ve:tt That wastes from vour operation =e le: inz,
overlow-ing. or running oil site. You should not wait until wastes reach silr ace waters or
leave vour property to consider that you have a prooiern. You should naive eve:v e:fort to
ensure that this does not happen. This plan should be posted In an accessible Iocation for
all tmoiovees at ih.- facile:. The fbilow•ing are some action ii=s •you should tok!.
I. Scoo the reie:,se or wastes. Deoendinv on the situation. this nav or may not be
possible. Sugges:ed responses to some possible probierns art listed below.
A. Lagoon overflow -possible solutions are:
a. Ada sou to be mL ro increase tie .'adon of dazm.
b. Pump wastes to Fields at an acceocaole rate.
c. Scot) all slows to ci±e IaaJon irnrnediaiel_v.
d. Call a ou:rnoinz contr_c_or.
e: Make sure no surface waver is enceins lagoon.
3: Runoff from waste application Ee'.d-actions include:
a_
b_
c.
d.
e.
i
1=, ediately stop waste application.
Create a te:noorarf diversion to contain waste.
Incorporate waste to reduce runoff.
Evaluate and eliaunate the reason(s) ghat caused the runoff
Evaluate the apoiic_tion MECS for the Melds where ,_noel occu:-:ed.
C_ Leakage from [he .vaS:e pines and sr nn_-;.lers-action include:
a. Scop recycle purnp.
b. Scop irrigation purnp.
c. Close valves :0,t3irm*'nate fur -her disczar_e_
d. Reoair all [eats prior co resa.rting pumps.
D: Leakage iron flush systerns. houses. solid separators -action include:
a. Stop recycle pump.
''U. Stop III.? ltloil Durn-c-
c. ma_�e start rIo sicnon oc_srs.
Sco❑ ail ;lows in th :souse. r`::a;i 5'•Ste:!s. or sc[:c
IS,. 1 �-q.6

e. Repair all leaks prior to restartin,* pumps.
E: Leakage from base or sidewalI of lagoon. Often this is seepag! as opoosed to
flowing leaks- possible action:
a. Diz a small sump or ditch away from the embank -meat to catch all seepaze.
put in a submersible pump. and puma back to lagoon.
b. If holes are caused by burrowinJ animals. trap or remove znirnals and ri:1
holes and compact with a c'.a_y nTe soil.
c. Have a proressional evaluate the condition of the side wails and laggoon
bottom as soon as possible.
?. Assess the e:,te:it of the spill and note anv obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much .vas released and for what du acion-,
c. Any damage noted. such as employee injury. fish kills. or prope ry dam" —?
d_ Did the spill leave the property'?
e. Does the spill have the ootential to reach surface waters?
f. Could a fuiure rain event cause the spill to reach surface %vat-.;?
Are potable water wells in danger (eit� on or o:i of the prole v}�
h. How much reached surtact wafters'
5: Contact appropriate agencies.
a. During norriaLbusiness hours, call your DWQ (Division of Water Qualit'.)
regional office; Phone - - After hours, emergency numbe- 919-f-3 -59,_.
Your phone call should include: your name. faciiicy, to?ejhcne number, the details
or the inc;dezt from item? above, the exact location of u`ie fac:iity, the location or
direction of movernenE of the spill. weather and wind conditions. 1ne corxec.ive
measures that have be_n undertaken, and the seriousness of the situation.
b. If soiIl leaves prope.-,v or eaters surface waters, call local ENIS Phone number -
c- Irstr•Lic: ENIS to contact local He_lth Deparmeni.
d. Contact CES. phone number - - , local SWCD office phone number
and local v-RCS office for advice!te_hnical assistance phone nu,n der - -
: If none of:he above works call 91 i or the Shenffs Deo=meac and exmiain vour
problem to then and ask that person to contact the proper agencies for vou.
J: Contact me C0nt:,4c:0r Of your choice to begin ref a_r of problem to rrunirrdze Oif-site
damage.
a. Cont actors ear -net S*C, (EdWIz Srn.'* ; 1QW"')
b- Contractors Address: o 3 ol 2,+1 u I Tut
c. Contrac:ors Phone: '110 - Sz4 — 5 -LS 1
ne^e:;:ber I S . 19L:o

5: Contact the technical soe_ialist who c:!rtiiied the lagoon (.RCS. CcnsUlting
En_Tine_:. etc.) -
a_ bsun )
h. Phone: ik-t67-7tb
! : Implement procedures as advised by DW Q and technical assisuric_ 2-crenc-es to
rectify the damaze. rec air the systern. and reassess the waste rnana_ernenc plan to
ke_a prohierns with r�'.ese or wastes irLirn haoveainQ _ sin.

Swine Farm Waste Management Odor Control Cheddisk
TSonrce Cause I 11h11's to Miniuilr.e Udor Site Specific 1'raclices
171111llstead Swine ploduclion Vcgelative or wooded bulreis;
Vq(;ood
ecommewled best i mlagentenl practices;
jlldglnew Inns common scuse
Animat body sulFaces Dilly nlanulc-coveled animuls I]ry Iluurs
7-hlor-mlInes Tel !!!:once -cc lvelell Ilnnts f Slotted llouls; --�
GI Watems located over slotled Moms;
V'Cellers III high crid ol'solill flools;
'scrape munlnc Imikluh lions !loots;
Cl Ulldcrlloorvcntilalionfor ttlying
malulle collection pill • UIine; fq Fletillcnl nllllllllc lelnovnl by Ilusll, pit lechalge, — — ---
• 11alli;1l miclubial dectnnllositimt or Smape;
Cl IJnticrlluur vculilalion
Vcntilauun a\ilitll5l ISMS Vul:Nile I;,tscs'
0 Ian nlainlcnanct:;
Uusi Ca�liflicient air nnlvcmcnl
luduor s ll finces • DIlsl W- WSISbtlolvll bcl►vccn gr oups of animals;
Iced additives;
❑ Uccdcr Covers;
rlJ FCC([ delivery downspout extenders to recdcl•
�coyel s
Ilusll I:niks Agilaliun orrecycled Iagoun FT Flush lank covers;
liquid while lacks sere Tilling, ❑ l:xtemi rill iines to hear bollom orlanks with
lulu -siphon veins
Fhlsh alleys Agilation d+rrinf; waslemiler CI Underfloor Ilusll with underfloor ventilation
convey:nice
Pit Icclmige points 9 Al;iialion of recycled hgoon Cl I-xtend lechalge [fines to near bollum urpits
litplid whilu pils arc filling ►yids anli-siphon vents
hilt slations 9 Agitation doting sump laid. ❑ Sully lailk covers
filling 111111 dlawdown
[Onside drain collection • Agilatiun tiering waslcwaler _ Ifox covers
111 Jnnclllnl boxes Collveyallce
AhIOC - Idovemher 11. 1996, Page 3

Sutrce �Cause� 1i1191's Iu 1llirliolize Will. She Specilic ('radices
Iiud of drainpil?es al Agilaticnr (Iul illg wastcwstcr is I :xlend dischal Ite point of (lilies III ldel ncalh —_
lagoon cuuveyallce lugonit ligoid level
Lagoon Surfaces 0 Vblalile gas ctnissiolls;
• Biological mixing;
• Agimlion
C)' Proper lagoon liquid capacily;
¢r Cot Iecl lagoon Slat Uq) procedulcs;
QV' Irlillimum surf lcc area-lo-volunlle ratio;
V Mininunn ltgill lion whcl• pumping;
Cl mcchanicnl aeration;
PI'UVen biological additives
IIIigadim) splinlclur • I ligh pltasnle agiltiuu; rC( Irrigalc on illy days willl Iilllc or nu wind;
lnuzzles0 Wirld dlil'l
C]' Minimum rccumrucndcd o lcmlhl nc5snlc�
Sturagt; lank ur basin
snll'ace
to I
p/ Pump ilnlAc near lagoon liquid sllrfacc;
D Pump frum sccol►d-singe lagoon
• I'allial micrubial decumposilioll; ❑ Iiotlom ur midlevel loading; w __
• Mixing while lilling;
• Agilalion when emplyhlg
❑ Tank covers;
Basin surface ands ursolids;
Cl Proven biological additives or oxidanls
Sellling basin sill face I'allial nliclubial dccunlpusilioll., Gr Gxleud thainpipe oullcls underuealll liquid
• I,-lixbng while filliltg; level;
• Agilaliun when emplying O"'Remove sellled solids leguhuly
Ivlanurc, slurry ur sladge
• Agiluliort when splcatling;
0
Soil injcclion of slulry/sludges;
spleadcl' oullcls
. Volatile gas emisslolls
Cl
Wash residual manure from spreader aller use;
fJ
Proven biological additives or oxidanls
uncoveled tnallulc,
0 Volatile gas emissions while
❑
Soil injcclion ol-slurry/sludges
_ chary or sllnlge on field
dry;lll;
IQ
Soil incorpulmiun within 48 Ills.;
slrrraccs
D
Spread in Thin uniform layers for Inllid drying;
f7 I'roVCII biological additives or oxidants
Dead allilaals 0 Calcass decompusitionl 0 !'roper disposition of carcasses
Dead lulinnal disposal • (.arcals dccumpositioll fJ Complete covethlb of Carcasses In bill -ill Ails;
Ills Cl I'loper localion/construction ofdisposal Ails
Incinerawls & incomplete combuslioll n Secondary slack bmners
ANIOC - Novembcl 11, 1996, ('age 4

Suurrc Cause HMI's In 1111ninlii.c N Silt S11edue I'rac KS
SUanling water aluuud • I111111oper 11111i11i1ge; 6 (Jlnde sold landscape such that miler dlaills
NOW • faliclobial dccumposilion of sma)' limn Iilcilitics
organic lunuer
h171u111c hacked oulu • Poolly mairllnined access Ioads Fatnl access load maintenance
public 1oa11s liuul fsunl
i1CcC5S
Addilimml Iufopmadou :
SmWe Nbumu A•lauagcnlenl . 02OU ltule/111v11' l'ackct
Shine 1)(01101ou Faint Poleutial Ullor Sum s and ltcmcllics ; Ia1Ai; I'acl Slice(
swine Pludoctiou Facility hbnnne (vlanagcalcnl: Ph Itecllarge - Lagoun Tlcalulcul ; IillAli 128-83
Swine I'loduclion Facility Nh mne Managcm "t Undcllluul Flush - I.aguun'l'lea mma ; IAIAE 129-88
!Apm n Design and Managelnem for livestock hJunnlc Tmitmcut mid Slulage ; EIIAF 103-83
Calibuiliull of hla11n1c and Wasimaler Alylicatimi Itr11611111c111 ; IrBAf, Facl Shcel
Controlling Odols 1,111111 Swine Buildings , I'll 1-33
Enviluunlculal Assumuce I'rogrum ; 141111C: b4antmi
Options for A•Ianllging Udur ; a lepoll hmn the Swhw O11uOislc I urce
Nuisance Couce ms in Auimal A•1cmulc Rmagcluea l)1k,1s arld INS ; I'itU1117, 1995 Coufcicuce i'locccdiags
AMOC: - Nuvenibcl 11. 1996. I'slgc 5
Available Mont :
NO, Comity Fxtcnsic,u (.'c 111cr
NCS11 - IIAF,
NCSII - IIAF.
NCSU - HAF
NCMJ - HAE
NCSU - S,vinc iixlcosion
NC Pm k I'1 oduccl s Assoc
NCSU AgH Conllnullicatinns
1.101 ida Coollcralivc lixiensioll

Insect Control Checklist for Animal Operations
sip if --~ _ 01115C iinii's to collb-ol 111srcis------ — - site Silecirc I'l acliccs
- - - -- - ----- -- I,irliitl Systems
I-Itlsll Gullels 0 Accumulation ol'solids _ I'lush System is desigied nod unneeded
sullicienlly lu rcrtlove liccunrtrlmted solids hoil
/ grdlels ns desigucd.
c-q RCIlIUvc IIIidl,illg of IM11uultllcd suiids al
Impolls arnl fins ('lusted Solids ( M.1irllain hil"llmis, Scllling. Ildsllls .111d lllls whele ----- - - -
pest bleeding is appalcill to nliiimin Ills;
cluslillg of solids to a depill ill-Ilu mule Ibcul G -
S melees over mule Than 3U^/o of' sill
Excessive vegclalive Mcayirig vegehiliun lvr lvinintain vegetalive conliol along franks of
Gluwlll lagoolls nlld ulllcl' hupolllldiicilts to IIICVCIIt
acclimillatiurl of decaying vegelative limiter
along milel's edge oil ilnlloundntcllt's Ilerinrcler.
Dry Systems
Fecdels Feud SIlillagt � Ucsigil, operate mild nlmiulnill (Ceti S)'slcllls (C.g,,
blmkcis -ml lrooglls) to minimize {Inc
acculnulatiuo ordecaying wmslafe.
FA cleall Ilp spillage of a rolllinc basis (c,g., 'I - 10
day interval dill inn; sumincr, 1 S-30 day interval
,daring winlcr).
l=ced Slolage • Accumulations oI feed lesidlles _ RCd11Ce Iiui51111C aCClllllnlaliurl within aid
luuund ilmnecliale Ilciimcicr of feed slorage
areas by insuring thainage awmy ['Ions site
;lndlur Ilruviding adequate conlaillnlcit (c.h.,
covered hill for blcwcr's g min and similar high
/Illoisttlic graill Ilrodllcls).
Gl Insl►ccl for mid miluve or break ill cocci minced
solids ill filler drills arulnl(l 1'ecd slaragc as
ncctled.
• AMIC - November 11, 11196, Page I

Sollrcc C-itise IIII-11's 11) Clllllrul Insccls — Slle tillcfl1 1: I'radque%
Animal I Itilllilll; Alcas • Accuntt bliuns ul'animal Nviistcs 1Ef V'limillale luw alcas Ihnt twIl muistlllc alullli
lull) Baal waslage fell .; mill tllhcr Imatilnls whelc w;ISIC
acclnmilates allll (lisfulbancc by animals is
/millillial.
In iviniulain fence lows allll llller sitllls arunnt)
allimnl bultling areas to millimize
accunlulaliuns ur tvasles (i.c., inspect For ;unl
Icnluvc ur bleak Ill) accumulatc(I snlllls as
necded ).
DIV WI;lrlulc Ilanlllirtb ACGnllabltluns of;minral %v;lslcs 0 Rclllove slllll;lge un n luutillc basis (e.g., 7 - 10
Systems slay inlerval t1m in1; sununcr; 15-30 slay inlel val
Ilrlring wirltcl) wbelc lnanulc is luallell rul' I;tull
1111111icatiun ur llisllus;ll.
I'luvillc I'm allcllualc lllaimige aruunll nl;nnnc
stockpiles,
blspecl Cur null 1eillovc or bleak till t)cctllmllmed
wades In Iiller sit Ills Illuullll Mockplles tlllll
mantll c halldlillg ;II'ca5 w% 11ceded.
Fur ntlllc iulillnl;lliun cunlacl flit: tuullclalive lixlcnsilln Sclvicc, Uclmlilucnl ur 1-111ollmlogy, 1)ux 7613, Nol lb Calulilm Sl;ltc Ullivelsily,
Raleigh, NC:, 2"1695-7613.
AM IC - November 11. 1996, Page 2

Mortality Management Methods
(c:leck which methods) are being_ impierneated)
]Burial thi__ ie-_ beneath the s1r:aC= of the wound Within 24 hours rafter
knowledse of the death. The burial must be at leas: 300 fe_t from any flowing
Seam or pubiic bodv oC water. - -
Rende^na at arenderine ci:intIicensed under G.S. lOc-?c3.,
Coanplete incineration
in the case of dead pouluv oniv. placing in a disposal pit of a size and design
aocrove by t:-le Deo:rl.,entor-='iCUlt'1IC
i Any rneEhod which in :he prOFessicna.l Oolnion of Ei e &_Ee V rerin,,r_ari woulCi
ilia e DOSSible the 5 Ivzlgre ar a d-,ad 1 al valid- w; `nd� �rer: v
of a Oi ail � s 4 :CuOL:E �.�ii_ •ii�
human or an:r.:al heal: ,- (W --iEten approval or the Sta-! ti eEerinar an must be
arac n-4.

State of North Carolina
Department of Environment
and Natural Resources
Michael F. Easley, Governor
William G. Ross Jr., Secretary
Kerr T. Stevens, Director
July 2, 2001
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Marshall Horne
Marshall Horne Farm
2595 Lamb Rd
Garland NC 28441
1 �1IF'WA
IT • 4
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
JUL 13 2001
DWO
Subject: Notification for Wettable Acre Determination
Animal Waste Management System
Marshall Horne Farm
Facility Number 82-381
Sampson County
Dear Marshal I Horne:
A letter dated January 15, 1999 was sent to advise you about concerns associated with Certified Animal
Waste Management Plans and the method by which the irrigated acres within the plans were calculated. Only
the acres that are wetted can be credited in the waste management plan as receiving waste application. Any
acreage within the plan that can not be reached by waste application equipment can not be used as part of your
plan.
An evaluation by Scott Faircloth on 7/27/99 was made to review the actual number of acres at your
facility that receive animal waste during land application. The evaluation of your facility has yielded one of
the following two results as indicated by the box marked with an "X".
Category 1:
The evaluation of your facility could not be completed due to a lack of information. Please
contact your Technical Specialist to assist in providing Scott Faircloth the necessary
information to potentially exempt your facility from undergoing a complete wettable acre
determination. Please submit this information to Scoft Faircloth, at 225 Green Street, Suite
714, Fayetteville, NC 28301, within in 90 days of the receipt of this letter. If you have any
questions please contact Scott Faircloth at [phone]. If within 90 days you are
unable to provide Scott Faircloth with the information you are automatically required
to complete a Wettable Acre Determination as described by Category 2 below, within
180 days of receipt of this letter.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

Notification for Wettable Acre Determination
Animal Waste Management System
Page 2
Category 2:
❑ Your facility has been identified by the Department of Environment and Natural Resources
as a facility that may have overestimated the number of acres actually receiving animal
waste. Therefore, some or all of your fields may be exceeding the allowable loading rates
set in your Certified Animal Waste Management Plan.
In order to resolve this issue, please contact a designated Technical Specialist to have him
or her conduct a Wettable Acre Determination for your facility. The Technical Specialist must
be one that has been approved by the Soil and Water Conservation Commission to conduct
Wettable Acre Determinations. Many Technical Specialist with the N.C. Cooperative Extension
Service, the Soil and Water Conservation Districts, the Natural Resources Conservation
Service, and the Division of Soil and Water Conservation have received this special
designation. You may also contact a private Technical Specialist who has received this
designation, or a Professional Engineer.
All needed modifications to your Animal Waste Management System must be made and
the Wettable Acres Determination Certification must be returned to DWQ within the next
180 days. If the needed modifications are not made and 'tf the form is not returned within the
required time, DWQ will be forced to take appropriate enforcement actions to bring this facility
into compliance. These actions may include civil penalty assessments, permit revocation,
and/or injunctive relief.
Once a Wettable Acre Determination has been completed, a copy of the attached Wettable
Acre Determination Certification must be submitted to the address listed on the form. Please
note that both the owner and the Technical Specialist must sign the certification. A copy of all
the Wettable Acre Determination documentation that applies to your Waste Utilization Plan
must be kept at your facility. DWQ and the Division of Soil & Water Conservation Staff will
review all documentation during their annual visit of your facility. An additional copy must by
kept on file at the local Soil & Water Conservation District Office. Please note that if you install
or modify your irrigation system, a designated Irrigation Specialist or a Professional Engineer
must also sign the Wettable Acre Determination Certification.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Sonya Avant of our
Central Office staff at [phone] ext_ 571.
Sincerely,
Kerr T. Stevens
cc: Fayetteville Regional Office
Sampson County Soil and Water Conservation District
Facility File
Murphy Family Farms

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Marshall Horne
Marshall Horne Farm
2595 Lamb Rd
Garland NC 28441
Dear Marshall Horne,
RECEIVED
max 1 2000
FAYETTEVILLE
REG. OFFICE
April 27, 2000
A74
• •
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject. Application No. AWS820381
Additional Information Request
Marshall Horne Farm
Animal Waste Operation
Sampson County
The Non -Discharge PermittinQ Unit has received some additional information I response to our letter of November
17, 1999. Further additional information is required before we can continue our review. Please address the following by May
27, 2000: V
1 _ The issue of an inactive lagoon present on your farm was not addressed in your latest submission. All inactive
lagoons should have lagoon closure plan. Please submit a plan for your inactive lagoon to be included in the
permit package.
2_ It appears that the waste utilization plan dated 10/23/97 and submitted with the permit package was not signed
by the landowner. Please sign. date, and submit copies of the signature page.
Please note that all "'UP recisions must be signed and dated by both the owner and the technical specialist.
Please reference the subject permit application number when providing the requested information. All information
should be signed, sealed, and submitted in duplicate to my attention at the address below. The information requested by this
letter must be submitted on or before May 27, 2000 or the Division will return your application as incomplete in accordance
with 15A N.C.A.C. 2H .0200 and your facility will be considered to be operating without a permit.
Please be advised that operation of the subject animal waste management system without a valid permit is a violation
of North Carolina General Statute 143-215.1 and will subject you to the enforcement authority of the Environmental
Management Commission.
If you have any questions regarding this request, please call me at [phone], extension 363.
Sincerely
JR Josh
i---
Non-D' charge Permitting Unit
cc: Favetteville Regional Office, Water Quality
Permit File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
Marshall Horne
Marshall Horne Farm
2595 Lamb Rd
Garland NC 28441
Dear Marshall Horne:
NF.IWA
IT 0 0
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURcEs
December 30, 1999 RECEI VED
,};*�" 11. 2000
13YETTMLLE
r'EG. OFFICE
Subject: Fertilizer Application Recordkeeping
Animal Waste Management System
Facility Number 82-381
Sampson County
This letter is being sent to clarify the recordkeeping requirement for Plant Available Nitrogen (PAN)
application on fields that are part of your Certified Animal Waste Management Plan.
In order to show that the agronomic loading rates for the crops being grown are not being exceeded, you
must keep records of all sources of nitrogen that are being added to these sites. This would include nitrogen
from all types of animal waste as well as municipal and industrial sludgestresiduals, and commercial fertilizers.
Beginning January 1, 2000, all nitrogen sources applied to land receiving animal waste are required to
be kept on the appropriate recordkeeping forms (i.e. IRRI, I1?R2, DRYI, DRY2, DRYS, SLUR1, SLUR2,
SLD1, and SLD2) and maintained in the facility records for review. The Division of Water Quality (DWQ)
compliance inspectors and Division of Soil and Water operation reviewers will review all recordkeeping during
routine inspections. Facilities not documenting all sources of nitrogen application will be subject to an
appropriate enforcement action.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Ms. Sonya Avant of the
DWQ staff at [phone] ext. 571.
Sincere]
Kerr T. Stevens, Director
Division of Water Quality
cc: Fayetteville Regional Office
Sampson County Soil and Water Conservation District
Facility File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

State of North Carolina
Department of Environment • 0
and Natural Resources R�v��V�®
Division of Water Quality
James B. Hunt, Jr., Governor NOV 2 3 19"
Bill Holman, Secretary NCDENR
Kerr T. Stevens, Director FAYETfEVILLE NORTH CAROLINA DEPARTMENT Or
REG. OFFICE ENVIRONMENT AND NATURAL RESouRcES
November 17, 1999
Marshall Horne
Marshall Horne Farm
2595 Lamb Rd
Garland NC 28441
Subject: Application No. AWS820381
Additional Information Request
Marshall Horne Farm
Animal Waste Operation
Sampson County
Dear Marshall Horne:
The Non -Discharge Permitting Unit has completed a preliminary engineering review of the subject application.
Additional information is required before we can continue our review. Please address the following by December 17, 1999:
Operation and Maintenance Plan for your lagoons is missing in the package.
Mortality management checklist is missing.
It appears that you have an inactive lagoon on the farm. All inactive lagoons should have a lagoon closure
plan which should be included in the permit package.
Please note that all WLIP revisions must be signed and dated by both the owner and the technical specialist.
Please reference the subject permit application number when providing the requested information. All information
should be signed, sealed, and submitted in duplicate to my attention at the address below. The information requested by this
letter must be submitted on or before December I7, 1999 or the Division will return your application as incomplete in
accordance with 15A N.C.A.C. 2H .0200 and your facility will be considered to be operating without a permit.
Please be advised that operation of the subject animal waste management system without a valid permit is a violation
of North Carolina General Statute 143-215.1 and wilf subject you to the enforcement authority of the Environmental
Management Commission.
If you have any questions regarding this request, please call me at [phone], extension 363.
ce ly,
nJR Jos
Soil S entist
cc: Fayetteville Regional Office, Water Quality
Permit File
Permitting Unit
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
Kerr T. Stevens, Director
May 14, 1999
CERTIFIED MAIL
RETURNCEIPT_ REQUESTED
Marshall Home
Marshall Horne Farm
2595 Lamb Rd
Garland NC 28441
Farm Number: 82 - 381
Dear Marshall Horne:
1 ,Vk?WAIT •
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENv1ii0NMENT ANo NATURAL RESOURCES
ECE6,` EE.)
MAY 1 9 1999
FAYMEVILLE.
REG. OFFICE
You are hereby notified that Marshall Horne Farm, in accordance with G.S. 143-215.10C, must
apply for coverage under an Animal Waste Operation General Permit. Upon receipt of this letter, your
farm has six 60 days to submit the attached application and all supporting documentation. In
accordance with Chapter 626 of 1995 Session Laws (Regular Session 1996), Section 19(c)(2), any
owner or operator who fails to submit an application by the date specified by the Department
SHALL NOT OPERATE the animal waste system after the specified date. Your application must
be returned within sixty (60) days of receipt of this letter. Failure to submit the application as required
may also subject your facility to a civil penalty and other enforcement actions for each day the facility is
operated following the due date of the application.
The attached application has been partially completed using information listed in your Animal
Waste Management Plan Certification Form. If any of the general or operation information listed is
incorrect please make corrections as noted on the application before returning the application package.
The signed original application, one copy of the signed application, two copies of a general location
map, and two copies of the Certified Animal Waste Management Plan must be returned to complete the
application package_ The completed package should be sent to the following address:
North Carolina Division of Water Quality
Water Quality Section
Non -Discharge Permitting Unit
Post Office Box 29535
Raleigh, NC 27626-0535
If you have any questions concerning this letter, please call J R Joshi at [phone] extension
363 or Jeffery Brown with the Fayetteville Regional Office at [phone].
Sincerely,
for Kerr T. Stevens
cc: Permit File (w/o encl_)
Fayetteville Regional Office (w/o encl.)
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper