820184_CORRESPONDENCE_20171231

NUH I H LAHULINA
Department of Environmental Qual

Waste Utilization Plan a.- [ O
®ENR-FRO
JUL 3 t 2014
Producer: Todd Marshall County: Sampson
Name of Farm: Marshall Livestock
Location: 4887 Harrells Hwy
Garland NC 28441
Phone: [phone]
Type of Operation: Feed -Finish
Number of Animal: 2940
Storage Structure: Anaerobic Lagoon
Method of Application: Irrigation
Amount of waste produced per year: 5586 ton/year
Amount of plant available N (PAN) produced/year: 6762 lbs./year
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface water and/or groundwater. The plant nutrients in the animal waste
should be used to reduce the amount of commercial fertilizer required for the crops in the
fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in the implementing your waste utilization plan in order to
maximize the fertilizer value of the waste and to ensure that it is applied in an environmentally
safe manner.
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall not be applied to land eroding at more than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are
established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is
frozen. Either of these conditions may in runoff to the surface waters which is not
allowed under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor problems.
6. To maximize the value of the nutrients for crops production and to reduce the potential for
pollution, the waste should be applied to a growing crop or applied not more than 30 days
prior to planting a crop or forages breaking dormancy. Injecting the waste or disking will
conserve nutrients and reduce odor problems.
This plan is based on the waste application method shown above. If you choose to change methods
in the future, you need to revise this plan. Nutrient levels for different applications methods are
not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. in some cases you may want to have plant analysis made, which
Owo

Marshall Livestock
Page 2
could allow additional waste to be applied. Provisions shall be made for the area receiving
waste to be flexible so as to accommodate changing waste analysis content and the crop type.
Lime must be applied to maintain pH in the optimum range for specific crop production. This
waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract No.
Pull No.
Soil Type
Crop
Code
Yield/Ac
Lbs. N
unit
Acres
Lbs N
Used
Month to
Apply
Lbs. N
Per Ac.
6454
1-1
Goldsboro
CB/HAY
6.5
46
5.83
1743
MAR-SEP
299
6454
1-1
Goldsboro
SG/OS
1
50
5.83
292
OCT-MAR.
50
6454
1-2
Goldsboro
CB/WAY
6.5
46
5.53
1653
MAR-SEP
299
6454
1-2
Goldsboro
SG/OS
1
s0
5.53
277
OCT-MAR
s0
6454
2-1
Wa ram
CB/HAY
5.4
49
2.49
657
MAR-SEP
264
6454
2-1
Wa ram
SG/OS
1
50
2.49
125
OCT-MAR
s0
6454
2-2
Wa ram
CB/HAY
5.4
49
2.49
657
MAR-SEP
264
6454
2-2
Wa ram
SG/OS
1
50
2.49
125
OCT-MAR
s0
6454
3-1
Blanton
CB/HAY
4.4
48
5.48
1162
MAR-SEP
212
6454
3-1
Blanton
SG/OS
1
50
5.48
274
OCT-MAR
50
6454
3-2
Blanton
I CB/HAY
4.4
48
5.48
1162
MAR-SEP
212
6454
3-2
Blanton
I SG/OS
1
50
1 5.481
2741
OCT-MAR
1 50
Total 27.30 8400 lbs.
Available Nitrogen 6762 lbs.
Surplus or deficit -1638 lbs.
Applying the above amount of waste is a big job. You should plan time and have appropriate equipment to apply
the waste in a timely manner.

Marshall Livestock Page 3
The applicator is cautioned that P and K may be over applied while meeting the N requirements. In the future,
regulations may require farmers in some parts of North Carolina to have a nutrient management plan that
addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields (i.e. small grain, etc. interseeded in bermudagrass), forage must be removed through
grazing, hay and /or silage. Where grazing, plants should be grazed when they reach a height of six to nine
inches. Cattle should be removed when plants are grazed to a height of four inches. In fields where small grain
etc. is to be removed for hay or silage, care should be exercised not to let small grain to reach maturity,
especially late in the season ( i.e. April or May) Shading may result if small grain gets too high and this will
definitely interfere with the stand of bermudagrass. This loss of stand will result in reduced yields and less
nitrogen being utilized. Rather than cutting small grain for hay or silage just before heading as is the normal
situation, you are encouraged to cut the small grain earlier. You may want to consider harvesting hay or silage
two to three times during the season, depending on the time small grain is planted in the fall.
The ideal time to interplant small grain, etc. is late September or early October . Drilling is recommended over
broadcasting. Bermudagrass should be grazed or mowed to a height of about two inches before drilling for best
results.
Caution must be exercised in grazing or haying summer annuals under,stressed conditions. Nitrate poisoning
may occur in livestock. Sampling forage or hay for nitrate levels is recommended.
Acres shown in the tables are considered to be the usable acres excluding required buffers, filters strips along
ditches, odd areas unable to be irrigated, and perimeter areas not receiving full application rates due to
equipment limitations. Actual total acres in the field listed may, and most likely will be, more than the acres
shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land application of sludge at agronomic rates.
The sludge will be nutrient rich and will require precautionary measures to prevent over application of nutrients
or other elements. Your production facility will produce approximately 1058 lbs. of plant available
nitrogen per year in the sludge.
If you remove sludge every 5 years you will have approximately 5292 lbs. of PAN to utilize. Assuming
you apply this PAN to hybrid bermudagrass hayland at the rate of 300 lbs/acre you will need 18
acres of land. If you apply the sludge to corn at the rate of 125 lbs. of nitrogen per acre you will need 42
acres of land. Please be aware that these are only estimates of the PAN and the land needed. Actual
requirements could vary by 25% depending on the sludge waste analysis, soil types, realistic yields, and
application methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation such that
runoff or ponding occurs. This rate is limited by initial soil moisture content, soil structure, soil texture, water
droplet size, and organic solids. The application amount should not exceed the available water holding capacity

Marshall Livestock
Page 4
of the soil at the time of irrigation nor should the plant available nitrogen applied exceed the nitrogen needs of
the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the producer and
irrigation designer to ensure that an irrigation system is installed to properly irrigate the acres shown in tables.
Failure to apply the recommended rates and amounts of nitrogen shown in the tables may make this plan
invalid.
The following table Is provided as a guide for establishing application rates and amounts.
Tract No.
Pull No.
Soil Type
Crop
Code
Applic.
Rate(in/hr)
Applic.
Amount
6454
1-1
Goldsboro
CB/HAY
0.5
1.0
6454
1-1
Goldsboro
SG/OS
0.5
1.0
6454
1-2
Goldsboro
CBMAY
0.5
1.0
6454
1-2
Goldsboro
SG/OS
0.5
1.0
6454
2-1
Wagram
CB/HAY
0.5
1.0
6454
2-1
Wagram
SG/OS
0.5
1.0
6454
2-2
Wagram
CB/HAY
0.5
1.0
6454
2-2
Wagram
SG/OS
0.5
1.0
6454
3-1
Blanton
CB/HAY
0.5
1.0
6454
3-1
Blanton
SG/OS
0.5
1.0
6454
3-2
Blanton
CB/HAY
0.5
1.0
6454
3-2
Blanton
SG/OS
0.5
1.0

Marshall Livestock
Page 5
This is the maximum application amount allowed for the soil assuming the amount of nitrogen allowed for the
crop is not over applied. In many situations the application amount shown cannot be applied because of the
nitrogen limitations. The maximum application amount shown can be applied under optimum soil conditions.
Your facility is designed for 180 days of temporary storage and the temporary storage must be removed on the
average of once every 6 months. In no instances should the volume of the waste be stored in your structure
be within the 25 year 24 hour storm storage or one foot of freeboard except in the event of the 25 year 24 hour
storm.
It is the responsibility of the producer and the waste applicator to ensure that the spreader equipment is operated
properly to apply the correct rates shown in the tables. Failure to apply the recommended rates and amounts of
nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you have receive the waste analysis report for assistance in determining the
amount of waste per acre and the proper application rate prior to applying the waste.
NARRATIVE OF OPERATION

Marshall Livestock Page 6
WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply waste. If the producer
does not own adequate land to properly dispose of waste, he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner of the facility to
secure an update of the Waste Utilization Plan when there is a change in the operation,
increase in the number of animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climatic conditions, and level
of management, unless there are regulations that restrict the rate of application for other
nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but less than 10 tons per acre per
year providing grass filter strips are installed where runoff leaves the field. (See FOTG
standard 393 - Filter Strip).
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland,
the waste may be broadcast provided the application does not occur during a season
prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate that runoff
does not occur offsite or to the surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10. Waste nutrients shall not be applied in fall or winter, for spring planted crops on soils with a
high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste
shall not be applied more than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and from any perennial stream or river (other than an irrigation ditch or canal. Animal
waste other than swine waste from facilities sited on or after October 1, 1995), shall not be
applied closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips).

Marshall Livestock Page 7
REQUIRED SPECIFICATIONS
(continued)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those owned
by he landowner.
14. Waste shall be applied in a manner not to reach other property and public right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainage ways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site by a "technical specialist".
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that causes no runoff or drift from the site.
16. Domestic and industrial waste from wash down facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
17. A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced as necessary to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidences of
erosion, leakage or discharge.
18. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20. Animal waste can be used in a rotation that includes vegetation and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied pre -plant with no further applications of animal waste
during the crop season.
21. Highly visible markers shall be installed to mark the top and the bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste analysis records shall be kept
for five (5) years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina regulations.

Page 8
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: Marshall Livestock
Owner/Manager Agreement Todd Marshall
I (we) understand and will follow and implement the specifications and the operation and maintenance proce-
dures established in the approved animal waste utilization plan for the farm named above. I (we) know that any
expansion to the existing design capacity of the waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the North Carolina Division of Water Quality
before the new animals are stocked. I (we) also understand that there must be no discharge of animal waste
from this system to the surface waters of the state from a storm event less severe than the 25-year, 24 hour
storm. The approved plan will be filed on -site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Todd Marshall
Name of Manager (If different from owner)
Signature:
Name of Person Preparing Plan: G. Glenn Clifton
Affiliation: Prestage Farms, Inc. Phone: [phone]
Address: P.O. Box 438
Clinton, NC 28329
Date: 7 —
Date:
Signature:. {� �J Val\1 hh Date: 7 a t

IRRIGATION SYSTEM PARAMETERS
Land Owner:
Address:
Telephone:
Todd Marshall (Marshall Livestock) Date:
4887 Harrells Hwy
Garland NC 28441 Facility No.
910-385-4228
TABLE 1- Field Specifications
07/29/2014
R2-184
County: Sampson
Field No.
and/or
Pull No.
Maximum
Usable
Size of
Field
Soil Type
Slope
(%)
Crop(s)
Maximum
Application
Rate
(in/hr)
Maximum
Application
per Irrigation
Cycle
(inches)
1-1
5.83
Goldsboro
0-2
CB/HAY
0.5
0.96
1-1
5.83
Goldsboro
0-2
SG/OS/MAY
0.5
0.96
1-2
5.53
Goldsboro
0-2
CB/WAY
0.5
0.96
1-2
5.53
Goldsboro
0-2
SG/OS/HAY
0.5
0.96
2-1
2.49
Wagram
0-6
CB/MAY
0.6
0.72
2-1
2.49
Wagram
0-6
SG/OS/HAY
0.6
0.72
2-2
2.49
Wa ram
0-6
CB/HAY
0.6
0.72
2-2
2.49
Wagram
o-6
SG/OS/HAY
0.6
0.72
3-1
5.48
Blanton
0-6
CB/HAY
0.75
0.72
3-1
5.48
Blanton
0-6
SG/OS/HAY
0.75
0.72
3-2
5.48
Blanton
0-6
CS/HAY
0.75
0.72
3-2
5.48
Blanton
0-6
SG/OS/HAY
0.75
0.72
27.30
Computed By
G. Glenn Clifton
Prestage farms, Inc

Land owner:
irrigation System
Designation:
Wetted Diameter:
Spacing:
Hydrant Layout:
Hard Hose Traveling Gun System
Todd Marshall Facility Number:
X Existing Irrigation System
290 feet
79%
230 feet
X Multiple Hydrants
82-184
New/Expanding
Irrigation System
Single Hydrant
Computed By:
G. Glenn Clifton
Prestage Farms, Inc.

21,
�I
1
1, 411�
r F T
d eia
tv
��� 'I'iili 1•I 'Ir lr��6�'Y ! € S � '� },� �"qa�'°"
� ° •IE!I!�! ..li j ;r � s ��'�'�°�'��{, � �,1�4. ' • � : gal .
R
Y ,V k
e
IlTli
lx ti t I
krI
;� � �k' , ! �I,?'��i' µ�'{ �'�f�'(!.iti'��� �Vl���! ° � �d�:e 3 I�E'�+ ��y �'��r�� �tTT'� P li•FI`„ , c li { ,j"aawla. wn_;,�
�urir
�� L�'
f AI'� .� y� � ' � is l � j. . ' E: '' °�' _�• � ,� ' :, �•
V,.1"
A -a,"+,.P,;�°
1 ?COfii'
i'fr. N5' [ r }r E:9Ff•v 7 .M�'} - , ' }'at•1,,� �{• V'' �`
� � �14"1��5�1���., f�' � ,�J �� � �,l:{'� ��.� Ii H��1� ��r!►�'�wi�pr��y r�h�q�� i;q `�
ti r :sf, r r } �n g- �Y{, q:, I q . i n IM I j irl
a } ��
�4 p''aiw
{; 11�l° IL
It r
`�, 3, o :v ' i .I'! • ! h '�I i' � � "'Yj ' : d +�6 1 .. `�. { {' 1� #t�' rry l,fF. u"f��..�` 'i � + �� �qy�G
F- t
E `M �yy1 1K� t;
PIT,{!q(
���„[I+ � � it z 4: 1ati ,�r �j r� Y y p r 1 k �`�� h" �r•,��' 'L1i.G
f y t'� . `"'�;, .�, � a ,~ dy �,�y� k+:'�"i�'y�,,A "�'� , � " . ,' hi4 �� I�y t 1 i,i �•d1` ����¥ t� n�l:'h ti i �1�1t � l��P �t�.
����'1 ` '•3 f ✓ q 4� '^ 1 t -1 - E 'f' 1y I�. ,1 fY fi} ! "�'F_. .. t " CR lil ,1 Y t ? +� f.�yi1,
'�i'���� r'41. M+ '3�- �•q, :'��`�:'rr' �:�. �".. fri }�{ri�i, ';1'3►,S�E{1 iq'"1;� •-

Waste Utilization Plan z .i7 { ��
0O`
Producer:
Todd Marshall
Name of Farm:
Marshall Livestock
Location:
4887 Harrells Hwy
Garland NC 28441
Phone:
910-385-4228
County: Sampson
RECEIVED
SEP 2 6 2014
Type of Operation: Feed -Finish
Number of Animal: 2940 QENR—FAYETTEVILLEREGIONAL OFFICE
Storage Structure: Anaerobic Lagoon
Method of Application: Irrigation
Amount of waste produced per year: 5586 ton/year
Amount of plant available N (PAN) produced/year: 6762 lbs./year
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface water and/or groundwater. The plant nutrients in the animal waste
should be used to reduce the amount of commercial fertilizer required for the crops in the
fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in the implementing your waste utilization plan in order to
maximize the fertilizer value of the waste and to ensure that it is applied in an environmentally
safe manner.
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall not be applied to land eroding at more than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are
established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is
frozen. Either of these conditions may in runoff to the surface waters which is not
allowed under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor problems.
6. To maximize the value of the nutrients for crops production and to reduce the potential for
pollution, the waste should be applied to a growing crop or applied not more than 30 days
prior to planting a crop or forages breaking dormancy. Injecting the waste or disking will
conserve nutrients and reduce odor problems.
This plan is based on the waste application method shown above. If you choose to change methods
in the future, you need to revise this plan. Nutrient levels for different applications methods are
not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. in some cases you may want to have plant analysis made, which

J
Marshall Livestock
Page 2
could allow additional waste to be applied. Provisions shall be made for the area receiving
waste to be flexible so as to accommodate changing waste analysis content and the crop type.
Lime must be applied to maintain pH in the optimum range for specific crop production. This
waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract No,
Pull No.
Soil Type
Crop
Code
Yield/Ac
Lbs. N
unit
Acres
Lbs N
Used
Month to
Apply
Lbs. N
Per Ac.
6454
1-1
Goldsboro
CB/GRAZE
4.9
46
5.83
1306
MAR-SEP
224
6454
1-1
Goldsboro
SG/GRAZE
1
50
5.83
292
OCT-MAR
50
6454
1-2
Goldsboro
CB/GRAZE
4.9
46
5.53
1239
MAR-SEP
224
6454
1-2
Goldsboro
SG/GRAZE
1
50
5.53
277
OCT-MAR
50
6454
2-1
Wagram
CB/HAY
5.4
49
2.49
657
MAR-SEP
264
6454
2-1
Wagram
SG/OS
1
50
2.49
125
OCT-MAR
50
6454
2-2
Wagram
CB/HAY
5.4
49
2.49
657
MAR-SEP
264
6454
2-2
Wagram
SG/OS
1
50
2.49
125
OCT-MAR
50
6454
3-1
Blanton
CB/HAY
4.4
48
5.48
1162
MAR-SEP
212
6454
3-1
Blanton
SG/OS
1
50
5.48
274
OCT-MAR
50
6454
3-2
Blanton
CB/HAY
4.4
48
5.48
1162
MAR-SEP
212
6454
3-2
Blanton
I SG/OS
1
I 5D
1 5.491
2741
OCT-MAR
I5D
Total 27.30 7548lbs.
Available Nitrogen 6762 lbs.
Surplus or deficit -786 lbs.
Applying the above amount of waste is a big job. You should plan time and have appropriate equipment to apply
the waste in a timely manner.

Marshall Livestock Page 3
The applicator is cautioned that P and K may be over applied while meeting the N requirements. In the future,
regulations may require farmers in some parts of North Carolina to have a nutrient management plan that
addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields (i.e. small grain, etc. interseeded in bermudagrass), forage must be removed through
grazing, hay and /or silage. Where grazing, plants should be grazed when they reach a height of six to nine
inches. Cattle should be removed when plants are grazed to a height of four inches. In fields where small grain
etc. is to be removed for hay or silage, care should be exercised not to let small grain to reach maturity, .
especially late in the season ( i.e. April or May) Shading may result if small grain gets too high and this will
definitely interfere with the stand of bermudagrass. This loss of stand will result in reduced yields and less
nitrogen being utilized. Rather than cutting small grain for hay or silage just before heading as is the normal
situation, you are encouraged to cut the small grain earlier. You may want to consider harvesting hay or silage
two to three times during the season, depending on the time small grain is planted In the fall.
The ideal time to interplant small grain, etc. is late September or early October. Drilling is recommended over
broadcasting. Bermudagrass should be grazed or mowed to a height of about two inches before drilling for best
results.
Caution must be exercised in grazing or haying summer annuals under stressed conditions. Nitrate poisoning
may occur in livestock. Sampling forage or hay for nitrate levels is recommended.
Acres shown in the tables are considered to be the usable acres excluding required buffers, filters strips along
ditches, odd areas unable to be irrigated, and perimeter areas not receiving full application rates due to
equipment limitations. Actual total acres in the field listed may, and most likely will be, more than the acres
shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land application of sludge at agronomic rates.
The sludge will be nutrient rich and will require precautionary measures to prevent over application of nutrients
or other elements. Your production facility will produce approximately 1058 lbs. of plant available
nitrogen per year in the sludge.
if you remove sludge every 5 years you will have approximately 5292 lbs. of PAN to utilize. Assuming
you apply this PAN to hybrid bermudagrass hayland at the rate of 300 lbs/acre you will need 18
acres of land. If you apply the sludge to corn at the rate of 125 lbs. of nitrogen per acre you will need 42
acres of land. Please be aware that these are only estimates of the PAN and the land needed. Actual
requirements could vary by 25% depending on the sludge waste analysis, soil types, realistic yields, and
application methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation such that
runoff or ponding occurs. This rate is limited by initial soil moisture content, soil structure, soil texture, water
droplet size, and organic solids. The application amount should not exceed the available water holding capacity

Marshall Livestock
Page 4
of the soil at the time of irrigation nor should the plant available nitrogen applied exceed the nitrogen needs of
the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the producer and
irrigation designer to ensure that an irrigation system is installed to properly irrigate the acres shown in tables.
Failure to apply the recommended rates and amounts of nitrogen shown in the tables may make this plan
invalid.
The following table is provided as a guide for establishing application rates and amounts.
Tract No.
Pull No.
Soil Type
Crop
Code
Applic.
Rate(in/hr)
Applic.
Amount
6454
1-1
Goldsboro
CB/GRAZE
0.5
1.0
6454
1-1
Goldsboro
SG/GRAZE
0.5
1.0
6454
1-2
Goldsboro
CB/GRAZE
0.5
1.0
6454
1-2
Goldsboro
SG/GRAZE
0.5
1.0
6454
2-1
Wagram
CB/HAY
0.5
1.0
6454
2-1
Wagram
SG/OS
0.5
1.0
6454
2-2
Wagram
CB/HAY
0.5
1.0
6454
2-2
Wagram
SG/OS
0.5
1.0
6454
3-1
Blanton
CB/HAY
0.5
1.0
6454
3-1
Blanton
SG/OS
0.5
1.0
6454
3-2
Blanton
CB/HAY
0.5
1.0
6454
3-2
Blanton
I SG/OS
0.5
1.0

Marshall Livestock
Page 5
This is the maximum application amount allowed for the soil assuming the amount of nitrogen allowed for the
crop is not over applied. In many situations the application amount shown cannot be applied because of the
nitrogen limitations. The maximum application amount shown can be applied under optimum soil conditions.
Your facility is designed for 180 days of temporary storage and the temporary storage must be removed on the
average of once every 6 months. In no instances should the volume of the waste be stored in your structure
be within the 25 year 24 hour storm storage or one foot of freeboard except in the event of the 25 year 24 hour
storm.
It is the responsibility of the producer and the waste applicator to ensure that the spreader equipment is operated
properly to apply the correct rates shown in the tables. Failure to apply the recommended rates and amounts of
nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you have receive the waste analysis report for assistance in determining the
amount of waste per acre and the proper application rate prior to applying the waste.
NARRATIVE OF OPERATION

Marshall Livestock Page 6
WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply waste. If the producer
does not own adequate land to properly dispose of waste, he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing him/her the
use of the [and for waste application. It is the responsibility of the owner of the facility to
secure an update of the Waste Utilization Plan when there is a change in the operation,
increase in the number of animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climatic conditions, and level
of management, unless there are regulations that restrict the rate of application for other
nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but less than 10 tons per acre per
year providing grass filter strips are installed where runoff leaves the field. (See FOTG
standard 393 - Filter Strip).
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland,
the waste may be broadcast provided the application does not occur during a season
prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate that runoff
does not occur offsite or to the surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a
high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste
shall not be applied more than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and from any perennial stream or river (other than an irrigation ditch or canal. Animal
waste other than swine waste from facilities sited on or after October 1, 1995), shall not be
applied closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips).

Marshall Livestock Page 7
REQUIRED SPECIFICATIONS
(continued)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those owned
by he landowner.
14. Waste shall be applied in a manner not to reach other property and public right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainage ways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site by a "technical specialist".
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that causes no runoff or drift from the site.
16.. Domestic and industrial waste from wash down facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
17. A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced as necessary to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidences of
erosion, leakage or discharge.
18. if animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan "which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should,bc•
kept on site.
20. Animal waste can be used in a rotation that Includes vegetation and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied pre -plant with no further applications of animal waste
during the crop season.
21. Highly visible markers shall be installed to mark the top and the bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste analysis records shall be kept
for five (5) years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina regulations.

Page 8
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: Marshall Livestock
Owner/Manager Agreement Todd Marshall
I (we) understand and will follow and implement the specifications and the operation and maintenance proce-
dures established in the approved animal waste utilization plan for the farm named above. I (we) know that any
expansion to the existing design capacity of the waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the North Carolina Division of Water Quality
before the new animals are stocked. I (we) also understand that there must be no discharge of animal waste
from this system to the surface waters of the state from a storm event less severe than the 25-year, 24 hour
storm. The approved plan will be filed on -site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Todd Marshall
IMP--�
Signature: 0z_
Name of Manager (If different from owner)
Signature:
Name of Person Preparing Plan:
Affiliation: Prestage Farms, Inc.
Address: P.O. Box 438
Clinton, NC 28329
Signature:
G. Glenn Clifton
Phone: [phone]
Date: 9- a &
Date:
Date: 9 I Z

Both
DFNR-,SRO
��
NCD� MAR 3 201�
North Carolina Department of Environment and Natural Resources
Division of Water Resources
Water Quality Programs
Pat McCrory Thomas A. Reeder John E. Skvarla, III
Governor Director Secretary
March 17, 2014
Steven T. Marshall and Anthony R. Marshall
Marshall Livestock
4887 Harrells Hwy
Garland, NC 28441
Subject: Certificate of Coverage No. AWS820184
Marshall Livestock
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
Dear Steven T. Marshall and Anthony R. Marshall:
In accordance with your request to change facility name received February 26, 2014, we are hereby
forwarding to you this Certificate of Coverage (CDC) issued to Steven T. Marshall and Anthony R.
Marshall, authorizing the operation of the subject animal waste management system in accordance with
General Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for the Marshall Livestock, located in Sampson County, with a swine animal capacity of
no greater than the following annual averages:
Wean to Finish: Feeder to Finish: 2940 Boar/Stud:
Wean to Feeder: Farrow'to Wean: - Gilts:
Farrow to Finish: Farrow to Feeder: Other:
If this is a Farrow to Wean or Farrow to Feeder operation, there may be one boar for each 15 sows. Where
boars are unnecessary, they may be replaced by an equivalent number of sows. Any of the sows may be
replaced by gilts at a rate of 4 gilts for every 3 sows.
The COC shall be effective from the date of issuance until September 30,.2014, and shall hereby void
Certificate of Coverage Number AWS820184 dated November 15, 2012. Pursuant to this CDC, you are
authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this CDC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this CDC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Please pay careful attention to the
retard keeping and monitoring conditions in this permit. Record keepingforms orms are unchanged with this
General Permit. Please continue to use the same record keeping forms.
1636 Mail Service Center, Raleigh, North Carolina 27699-1636
Location: 512 N. Salisbury St Rale'Uh, North Carolina 27604
Phone, 91M07.64641 FAX: [phone]
Internet: wm,ncwate!gualitY-orq
An Equal Opportunity 1 Affirmative Action Employer

If your Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Per 15A NCAC 2T .0105(h) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100-foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, then an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Unit for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition 11.22 of the General Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Tropical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You
may find detailed watch/warning information for your county by calling the Raleigh, NC National
Weather Service office at [phone], or by visiting their website at: www.erh.noaa.gov/er/rah/
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Water Quality Regional Operations Section Staff may be reached at [phone]. If you need
additional information concerning this COC or the General Permit, please contact the Animal Feeding
Operations Branch staff at [phone].
Sincerely,
g, 9" - --
for Thomas A. Reeder
Enclosure (General Permit AWG100000)
cc: (Certificate of Coverage only for all ccs)
Fayetteville Regional Office, Water Quality Regional Operations Section
Sampson County Health Department
Sampson County Soil and Water Conservation District
WQROS Central Files (Permit No. AWS820184)
AFO Notebooks
Murphy -Brown, LLC

DENR-FRO
NOV 19 2012
CCDENR DWQ
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Charles Wakild, P.E. Dee Freeman
Governor Director Secretary
November 15, 2012
Steven T. Marshall and Anthony R. Marshall
S.E.A. Livestock, Inc.
4887 Harrells Hwy
Garland, NC 28441
Subject: Certificate of Coverage No. AWS820184
S.E.A. Livestock, Inc.
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
Dear Steven T. Marshall and Anthony R. Marshall:
In accordance with your Notification of Change of Ownership received November 15, 2012, we are
hereby forwarding to you this Certificate of Coverage (COC) issued to Steven T. Marshall and Anthony
R. Marshall, authorizing the operation of the subject animal waste management system in accordance
with General Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited, to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for the S.E.A. Livestock, Inc., located in Sampson County, with a swine animal capacity
of no greater than the following annual averages:
Wean to Finish: Feeder to Finish: 2940 Boar/Stud:
Wean to Feeder: Farrow to Wean: Gilts:
Farrow to Finish: Farrow to Feeder: Other:
If this is a Farrow to Wean or Farrow to Feeder operation, there may be one boar for each 15 sows. Where
boars are unnecessary, they may be replaced by an equivalent number of sows. Any of the sows may be
replaced by gilts at a rate of 4 gilts for every 3 sows.
The COC shall be effective from the date of issuance until September 30, .2014, and shall hereby void
Certificate of Coverage Number AWS820184 dated October 1, 2009. Pursuant to this COC, you are -
authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Please pay careful attention to the
record keeping and monitoring conditions in this permit. Record keeping forms are unchanged with this
General Permit. Please continue to usethe same record keeping forms.
1636 Mail Service Center, Raleigh, North Carolina 27699-1636
Location: 512 N. Salisbury St, Raleigh, North Carolina 27604
Phone: [phone] FAX: [phone] _
Internet: www.ncwetemuality.nra
NorthCarolina
Naturally
An Equal Opportunity 1 Affirmative Action Employer

If your Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Per 15A NCAC 2T .0105(h) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100-foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, then an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Unit for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition II.22 of the General Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Tropical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You
may find detailed watch/warning information for your county by calling the Raleigh, NC National
Weather Service office at [phone], or by visiting their website at: www.erh.noaa.j4ov/er/rah/
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Aquifer Protection Staff may be reached at [phone]. If you need additional information
concerning this COC or the General Permit, please contact the Animal Feeding Operations Unit staff at
[phone].
Sincerely,
for Charles Wakild, P.E.
Enclosure (General Permit AWG100000)
cc: (Certificate of Coverage only for all ccs)
Fayetteville Regional Office, Aquifer Protection Section
Sampson County Health Department
Sampson County Soil and Water Conservation District
APS Central Files (Permit No. AWS820184)
AFO Notebooks
Murphy -Brown, LLC

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Coleen H. Sullins, Director
Division of Water Quality
July 1, 2007
Sherwood E Allcox ^►-
S.E.A. Livestock ''i 7 27
255 Fork Lake Dr
Clinton, NC 28328
Subject: Certificate of Coverage No. AWS820184
S.E.A. Livestock
Animal Waste Management System
Sampson County
Dear Sherwood E Allcox:
In accordance with your application received on 18-Jan-07, we are hereby forwarding to you this
Certificate of Coverage (COC) issued to Sherwood E Allcox, authorizing the operation of the subject
animal waste management system in accordance with General Permit AWG 1000.00.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for the SI A. Livestock, located in Sampson County, with an animal capacity of no
greater than the following swine annual averages:
Wean to Finish: 0 Feeder to Finish: 2940 Boar/Stud: 0
Wean to Feeder: 0 Farrow to Wean: 0 Gilts: 0
Farrow to Finish: 0 Farrow to Feeder: 0
If this is a Farrow to Wean or Farrow to Feeder operation, there may also be one boar for each 15 sows.
Where boars are unneccessary, they may be replaced by an equivalent number of sows. Any of the sows
may be replaced by gilts at a rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009 and replaces the NPDES
COC issued to this facility with an expiration date of July 1, 2007. You are required to continue
conducting annual surveys of sludge accumulation in all lagoons at your facility; the one-year extension
in Condition III.19 does not apply.
Pursuant to this COC, you are authorized and required to operate the system in conformity with the
conditions and limitations as specified in the General Permit, the facility's CAWMP, and this COC. An
adequate system for collecting and maintaining the required monitoring data and operational information
must be established for this facility. Any increase in waste production greater than the certified design
capacity or increase in number of animals authorized by this COC (as provided above) will require a
modification to the CAWMP and this COC and must be completed prior to actual increase in either
wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Enclosed for your convenience is
a package containing the new and revised forms used for record keeping and reporting. Please
careful attention to the record keeping and monitoring conditions in this permit. ,
Aquifer Protection Section 1636 Mail Service Center
Internet: www.ncwatemualitv.ore Location: 2728 Capital Boulevard
An Equal Opportunity/Affirmative Action Employer— 50% Recycledl10% Post Consumer Paper
t
Carolina
Raleigh, NC 27699-1636 Telephone: [phone]
Raleigh, NC 27604 Fax 1: [phone]
Fax 2: [phone]
Customer Service: [phone]

If your Waste Utilization Plan has been developed based on site -specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 02T .0111(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100-foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Per 15A NCAC 02T .1306, any containment basin, such as a lagoon or waste storage structure, shall
continue to be subject to the conditions and requirements of the facility's permit until closed to NRCS
standards and the permit is rescinded by the Division.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Aquifer Protection staff may be reached at 910-433-3300. If you need additional information concerning
this COC or the General Permit, please contact the Animal Feeding Operations Unit staff at (919) 733-
3221.
Sincerely,
for Coleen H. Sullins
Enclosures (General Permit AWG 100000, Record Keeping and Reporting Package)
cc: (Certificate of Coverage only for all cc's)
Sampson County Health Department
Sampson County Soil and Water Conservation District
Fayetteville Regional Office, Aquifer Protection Section
AFO Unit Central Files
Permit File AWS820184

Nutrient Management Plan For Animal Waste Utilization
07-12-2001 h ^' 4 2
This plan has been prepared for:
This plan has been developed by:
S. E.A. Livestock Jason XlcAfee
Sherwood Allcox NRCS
255 Lake Drive 84 County Complex Rd
Clinton, NC 28328 Clinton, NC 28328
910592-3638 910592-7963 Ext 3
Type of Plan:
D toper Signature
Nitrogen Only with Ma ure Only
Owner/Manager/Producer Agreement
I (we) understand and agree to the specifications and the operation and maintenance
procedures established in this nutrient management plan which includes an animal waste
utilization plan for the farm named above. I have read and understand the Required
Specifications concerning animal waste management that are included with this plan.
2e 6
Signature (owner) ate
Signature (ma ager or producer) Date
This plan meets the minimum standards and specifications of the U.S. Department of
Agriculture - Natural Resources Conservation Service or the standard of practices
adopted by the Soil and Water Conservation Commission.
Plan Approved Bv: rJ
Technic- Specialist Signature Date
321 165 Database Version 1.06 Date Printed: 07-12-2001 Cover Page 1
RECEIVED I DENR 1 DWQ
Aquifer Protection Section
MAR 2 5 2009

Narrative
Based on a new wettable acre determination the revised Animal Waste Utilazation Plan has a new balance
of -1471 LBS AW N Used.
A couple of factors to be aware of are:
(1) On fields (2 and 3) the ordinal WUP LBS AW N PER AC was used. On field (1) LBS AW N PER
AC was used by the new nutrient mangement program for the revised waste management plan. The
orginai WUP LBS AW N PER AC could not be used because the change in crops and/or cropping pattern
was in field (1).
(2) Mr. Allcox has Millet planted in field 1 at this time. He is aware that if lie continues with the
Nlillet/Winter Annual rotation he will not have enough acreage to fully utilize the animal waste N
produced. Mr. Allcox has agreed to sprig Coastal, hybrid bermudagrass in field l between March I to
March 31 of vear 2002 and a small grain overseed in the Fall of 2002.
(3)WUP AMENDMENT -A WUP amendment is a change and/or addition to a part(s) of the plan, and
requires that the change and /or addition adhere to current applicable standards. In an existing WUP, a
change in crops and/or cropping pattern that utilizes 25% or less of the N generated is considered a plan
amendment. (Millet/Winter annual to Coastal hybrid, berill Lida grass/Overseed Small Grain).
321165 Database Version 1.06 Date Printed: 07-12-2001 Narrative Page 1

Nutrients applied in'accordance with this plan will be supplied from the
following source(s): '
Commercial Fertilizer is not included in this plan.
S7
Swine Feeder -Finish Lagoon Li uid waste Eenerated 2,725.380 als/year
by a 2.940 animal Swine Finishing Lagoon Liquid o eration. This
production facility has waste storage ca acities of approximately 180 da s.
Estimated Pounds of Plant Available Nitrogen Generated per Year
Broadcast
6281
Incorporated
10787
Injected
11879
Irrigated
6827
Actual PAN Applied
Year 1 8298
Notes:
In source 1D, S means standard source, U means user defined source.
321 165 Database Version 1.06 Date Printed: 7/12/01 Source Page 1

The Waste Utilization table shown below summarizes the waste utilization plan for this operation. This plan provides an estimate of the number of acres of
cropland needed to use the nutrients being produced. The plan requires consideration of the realistic yields of the crops to be grown, their nutrient requirements,
and proper tinting of applications to maximize nutrient uptake.
This table provides an estimate of the amount of nitrogen required by the crop being grown and an estimate of the nitrogen amount beingsupplied by manure or
other by-products, commercial fertilizer and residual from previous crops. An estimate of the quantity of solid and liquid waste that will be applied on each field in
order to supply the indicated quantity of nitrogen from each source is also included -
A balance of the total manure produced and the total manure applied is included in the table to ensure that the plan adequately provides for the utilization of the
manure generated by the operation. Animal operations that generate liquid waste and utilize waste storage facilities (lagoons or holding ponds) may apply more or
less waste in any given year than is annually generated by the facility. In order to determine whether the plan adequately utilizes the waste produced by the facility,
the storage capacity table included in this plan should be reviewed to ensure that the design capacity of the storage facility is not exceeded during the planning
period.
Depending on the requirements of the crop and the nutrient content of the waste, some nutrients will likely be over or under applied if animal waste is being
utilized. Waste should be analyzed before each application cycle and annual soil tests are required if animal waste is being applied. Soil tests should be used to
balance the nutrient application amounts with the realistic yields of the crop to be grown. Nutrient management plans may require that the application ofanimal
waste be limited so as to prevent over application of phosphorous when excessive levels of this nutrient are detected in a field.
Waste Utilization Table
Year 1
Tract
Field
Source
LI).
Soil Series
Total
Acre
Use.
Acres
Crop
RYE-
RYE
Unit
Applic.
Period
Nitrogen
PA
Nutrient
Req'd
[ /A
Comm.
Fert.
Nutrient
Applied
h
Res.
(Ibs/A)
N
Applic.
Method
Manure
PA
Nutrient
Applied
Liquid
Manure
Applied
(acre)
Solid
Manure
Applied
(acre)
Liquid
Manure
Applied
(Field)
Solid
Manure
Applied
(Field)
N
N
IbsIA
1000
sal/A
tons
1000 gals
tons
6454
1
S7
Goldsboro
11.8
11.3
mall Grain Oversced
11.0
"Cons
1011-3/31
50
0
0
brig.
50
20.0
0.0
224.8
0.0
6454
1
S7
Goldsboro
1 1.8
11.3
3ffmudaggrass Hay
06.5
Tons
311-9/30
296
U
0
[Frig.
296
118.2
0.0
i,330-5
0.0
6454
2
S7
Wagrant
5.0
4.1
'mail Grain Overseed
1.0
Tons
10/1-3131
50
0
0
[frig.
50
20,0
0-0
9L8
ob
6454
2
S7
Wa ram
5.0
4.1
3erntudagrass 11a
5.5
Tons
311-9/30
275
0
0
[trig.
275
I09-8
0.0
505.0
0.0
6454
3
57
nlartton
t3.5
11.2
mall Grain Ovetseed
I.0
Vrons
IO/l 3/31
50
U
0
brig.
50
20.0
0.0
223.81
0.0
321 163 Database Version 1.06 Date Printed: 07-12-2001 WUT Page I

Waste Utilization Table
Year 1
Tract
Field
Source
I.D.
Soil Series
Total
Acre
Use.
Acres
Crop
RYE
RYE
I Unit
Applic-
Period
Nitrogen
PA
Nutrient
Req'd
1bs1.4
Comm.
Fert.
Nutrient
Applied
IMIA)
Iles.
(lbslA)
I N
Applic.
I Method
Manure
PA
Nutrient
Applied
Liquid
Manure
Applied
(acre)
Solid
Manure
Applied
(acre)
Liquid
Manure
Applied
(Field)
Solid
Manure
Applied
(Field)
N
N
Ibs/A
1000
gal/A
tons
1000 eats
tons
64i4
3
S7
Blanton
13.5
11.2
Illermudagrass Ilav
1 45
ITons
3/1-9130
1r 2251
0
1 U
1 brie.
1 2251
89.81
0.0
L006.9
0.0
Lagoon Liquids
Total Applied, 1000 gallons
3.383
Total Produced, 1000 gallons
2,725
Balance. 1000 ealtons
-657
Manure Solids
Total Applied, tons
Total Produced. tuns
100
Balance -tuns
Notes: 1. In the tract column, symbol — means leased, otherwise, owned.
2. Symbol' means user entered data.
. ............. -•- ......... .... - — — . ........... .... ...........
321165 Database Version 1,06 Date Printed: 07-12-2001 WUT Page 2

The Irrigation Application Factors for each field in this plan are shown in the following table.
Infiltration rate varies with soils. If applying waste nutrients through an irrigation system, you must apply
at a rate that will not result in runoff. This table provides the maximum application rate per hour that may
be applied to each Field selected to receive wastewater. It also lists the maximum application amount that
each field may receive in any one application event.
lrr4mtion Application Factors
Tract
Field
Soil Series
Application Rate
(inches/hour)
Application Amount
i (inches)
6454
1
Guldshoro
0.50
0.96
6454
2
W aLram
0.60
0.72
6454
3
Blanton
0.75
0.48
.... ........ ..........
321165 Database Version I,06 Date Printed:. 12-.. .. D7-12DDl lAF Page 1

The following Lagoon Sludge Nitrogen Utilization table provides an estimate of the number of acres needed for
sludge utilization for the indicated accumulation period. These estimates are based on average nitrogen
concentrations for each source, the nulnber of animals in the facility and the plant available nitrogen application
rates shown in the second column.
Lagoon sludge contains nutrients and organic matter remaining after treatment and application of the effluent. At
clean out, this material must be utilized for crop production and applied at agronomic rates. In most cases, the
priority nutrient is nitrogen but other nutrients including phosphorous, copper and zinc can also be limiting. Since
nutrient levels are generally very high, application of sludge must be carefully applied.
Sites must first be evaluated for their suitability for sludge application. Ideally, effluent spray fields should not be
used for sludge application. If this is not possible, care should be taken not to load effluent application fields with
high amounts of copper and zinc so that additional effluent cannot be applied. On sites vulnerable to surface water
moving to streams and lakes, phosphorous is a concern. Soils containing very high phosphorous levels may also be
a concern.
Lagoon Sludge Nitrogen Utilization Table
Crop
ximum
LPA-NRate
b/ac
Maximum Sludge
Application Rate
1000 aallac
Minimum Acres
5 Years Accumulation
Minimum Acres
10 Years Accumulation
Minimum Acres
15 Years Accumulation
Swine Feeder -Finish Lagoon Sludge - Standard
Corn 120 bu
1501
13.16
36.86
73.71
110.57
Hay 6 ton R.Y.E.
300
26.32
18.43
36,86
55.29
Soybean 40 bu
160
14.04
34.35
69.11
103.66
........ ........... .
- 321165 Database Version 1.06 Date Printed: 07-12 a2001 Sludge a PPa e 1

The Available Waste Storage Capacity table provides an estimate of the number of days of storage
capacity available at the end of each month of the plan. Available storage capacity is calculated as the
design storage capacity in days minus the number of days of net storage volume accumulated. The start
date is a value entered by the user and is defined as the date prior to applying nutrients to the first crop in
the plan at which storage volume in the lagoon or holding pond is equal to zero.
Available storage capacity should be greater than or equal to zero and less than or equal to the design
storage capacity of the facility. If the available storage capacity is greater than the design storage
capacity, this indicates that the plan calls for the application of nutrients that have not yet accumulated. If
available storage capacity is negative, the estimated volume of accumulated waste exceeds the design
storage volume of the structure. Either of these situations indicates that the planned application interval
in the waste utilization plan is inconsistent with the structure's temporary storage capacity.
Available Waste Storage Capacity
Source Name
Swine Feeder -Finish Lagoon Liquid
Design Storage Capacity (Days)
Start Date
1 08/01
180
Plan Year
Month
Available Storage Capacity (Days)
1
1
47
1
2
33
1
3
85
1
4
131
1
5
176
1
6
180
]
7
180
1
8
180
1
9
180
1
10
163
I
11
147
k
1 12
123
* Available Storage Capacity is calculated as of the end of each month.
.................... ......I .... ......... .. ..........---- ...... - ... -- —.......... .......... ............. .— .............
321165 Database Version 1.06 Date Printed: 07-12-2001 Capacity Page 1

Required Specifications For Animal Waste Management
1. Animal waste shall not reach surface waters of the state by runoff, drift,
manmade conveyances, direct application, or direct discharge during
operation or land application. Any discharge of waste that reaches
surface water is prohibited.
2. There must be documentation in the design folder that the producer
either owns or has an agreement for use of adequate land on which to
properly apply the waste. If the producer does not own adequate land to
properly dispose of the waste, he/she shall provide evidence of an
agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the
responsibility of the owner of the waste production facility to secure an
update of the Nutrient Management Plan when there is a change in the
operation, increase in the number of animals, method of application,
receiving crop type, or available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs
for realistic crop yields based upon soil type, available moisture, historical
data, climatic conditions, and level of management, unless there are
regulations that restrict the rate of applications for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre
per year. Waste may be applied to land eroding at more than 5 tons per
acre per year but less than IO tons per acre per year provided grass filter
strips are installed where runoff leaves the field (see USDA, NRCS Field
Office Technical Guide Standard 393 - Filter Strips).
5. Odors can be reduced by injecting the waste or by disking after waste
application. Waste should not be applied when there is danger of drift
from the land application field.
b. When animal waste is to be applied on acres subject to flooding, waste
will be soil incorporated on conventionally tilled cropland. When waste is
applied to conservation tilled crops or grassland, the waste may be
broadcast provided the application does not occur during a season prone
to flooding (see "Weather. and Climate in North Carolina" for guidance).
7. Liquid waste shall be applied at rates not to exceed the soil infiltration
321165 Database Version 1.06 Date Printed: 07-12-2001 Specification Page 1

rate such that runoff does not occur offsite or to surface waters and in a
method which does not cause drift from the site during application. No
ponding should occur in order to control odor and flies.
S. Animal waste shall not be applied to saturated soils, during rainfall
events, or when the soil surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner
that the crop is not covered with waste to a depth that would inhibit
growth. The potential for salt damage from animal waste should also be
considered.
.10. Nutrients from waste shall not be applied in fall or winter for spring
planted crops on soils with a high potential for leaching. Waste/nutrient
loading rates on these soils should be held to a minimum and a suitable
winter cover crop planted to take up released nutrients. Waste shall not
be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with
the following: The outer perimeter of the land area onto which waste is
applied from a lagoon that is a component of a swine farm shall be at
least 50 feet from any residential property boundary and canal. Animal
waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer that 25 feet to perennial waters.
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other
than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and
public right-of-ways.
15. Animal waste shall not be, discharged into surface waters, drainageways,
or wetlands by a discharge or by over -spraying. Animal waste may be
applied to prior converted cropland provided the fields have been
approved as a land application site by a "technical specialist". Animal
waste shall not be applied on grassed waterways that discharge directly
into water courses, and on other grassed waterways, waste shall be
321 165 Database Version 1.06 Date Printed: 07-12-2001 Specification Page

applied at agronomic rates in a manner that causes no runoff or drift
from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets,
sinks, etc., shall not be discharged into the animal waste management
system.
17. A protective cover of appropriate vegetation will be established on all
disturbed areas (lagoon embankments, berms, pipe runs, etc.). Areas
shall be fenced, as necessary, to protect the vegetation. Vegetation such
as trees, shrubs, anti other woody species, etc., are limited to areas where
considered appropriate. Lagoon areas should be kept mowed and
accessible. Berms and structures should be inspected regularly for
evidence of erosion, leakage, or discharge.
18. If animal production at the facility is to be suspended or terminated, the
owner is responsible for obtaining and implementing a "closure plan"
which will eliminate the possibility of an illegal discharge, pollution, and
erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected
on a regular basis to prevent breakdowns, leaks, and spills. A regular
maintenance checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other
crops for direct human consumption. However, if animal waste is used
on crops for direct human consumption, it should only be applied
pre -plant with no further applications of animal waste during the crop
season.
21. Highly visible markers shall be installed to mark the top and bottom
elevations of the temporary storage (pumping volume) of all waste
treatment lagoons. Pumping shall be managed to maintain the liquid
level between the markers. A marker will be required to mark the
maximum storage volume for waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested
at least annually at crop sites where waste products are applied. Nitrogen
shall be the rate -determining nutrient, unless other restrictions require
.................. .......... .........`.fic
......... . .........................
321 165 Database Version 1.06 Date Printed: 07-12-2001 Specification Page 3

waste to be applied based on other nutrients, resulting in a lower
application rate than a nitrogen based rate. Zinc and copper levels in the
soils shall be monitored and alternative crop sites shall be used when
these metals approach excessive levels. pH shall be adjusted and
maintained for optimum crop production. Soil and waste analysis
records shall be kept for a minimum of five years. Poultry dry waste
application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a
minimum of five years.
23. Dead animals will be disposed of in a manner that meets North Carolina
regulations.
...... ................ ....
321 165 Database Version 1.06 Date Printed: 07-12-2001 Specification Page 4

Crop Notes
The following crop note applies to field(s): 1
Bermudagrass Coastal Plain, Mineral Soil, Poorly Drained to Somewhat Poorly Drained.
Adaptation: Effective artificial drainage MUST be in place to achieve Realistic Yield Expectations
provided for these soils.
In the Coastal Plain, hybrid bermudagrass sprigs can be planted Mar. 1 to Mar. 3l . Cover sprigs I" to 3"
deep (1.5" optimal). Sprigs should be planted quickly after digging and not allowed to dry in sun and
wind. For Coastal and Tifton 78 plant at least 10 bulac in 3' rows, spaced 2' to 3' in the row. Generally a
rate of 30 bu/ac is satisfactory to produce full groundcover in one or two years under good growing
conditions. Tifton 44 spreads slowly, so use at least 40 bu/ac in 1.5' to 2' rows spaced I' to 1.5' in row.
For broadcast/disked-in sprigs use about 60 bulac. Soil test for the amounts of lime, phosphorus,
potassium and micronutrients to apply preplant and for annual maintenance. Apply 60 to 100 lb/ac N in
the establishment year in split applications in April and July. For established stands apply 180 to 240
Ib/ac N annually in split applications, usually in April and following the first and second hay cuts. Reduce
N rates by 25% for grazing. Refer to NCSU Technical Bulletin 305 Production and Utilization of
Pastures and Forages in North Carolina for more information or consult your regional agronomist or
extension agent for assistance.
The following crop note applies to field(s): l
Small Grain: CP, Mineral Soil, low -leachable
In the Coastal Plain, oats and barley should be planted from October 15-October 30; and rye from
October 15-November 20. For barley, plant 22 seed/drill row foot and increase the seeding rate by 5% for
each week seeding is delayed beyond the optimum time. See the seeding rates table for applicable seeding
rate modifications in the current NCSU "Small Grain Production Guide". Also, increase the initial
seeding rate by at least 10% when planting no -till. Oats should be planted at 2 bushels/acre and rye at 1-1
1/2 bushels/acre. Plant all these small grains at 1-1 1/2" deep. Adequate depth control is essential. Review
the NCSU Official Variety "green book" and information from private companies to select a high yielding
variety with the characteristics needed for your area and conditions. Apply no more than 30 Ibslacre N at
planting. Phosphorus and potash recommended by a soil test can also be applied at this time. The
remaining N should be applied during the months of February -March.
The following crop note applies to field(s)
Bermudagrass Coastal Plain, Mineral Soil, Moderately Well Drained.
Adaptation: Well -adapted.
In the Coastal Plain, hybrid bermudagrass sprigs can be planted Mar. I to Mar. 31. Cover sprigs I" to 3"
deep (V .5" optimal). Sprigs should be planted quickly after digging and not allowed to dry in sun and
wind. For Coastal and Tifton 78 plant at least 10 bu/ac in 3' rows, spaced 2' to 3' in the row, Generally a
rate of 30 bulac is satisfactory to produce full groundcover in one or two years under good growing
conditions. Tifton 44 spreads slowly, so use at least 40 bu/ac in 1.5' to 2' rows spaced !' to 1.5' in row.
For broadcast/disked-in sprigs use about 60 bu/ac. Soil test for the amounts of lime, phosphorus,
potassium and micronutrients to apply preplant and for annual maintenance. Apply 60 to 100 lb/ac N in
321165 Database Version 1.06 Date Printed: 07-12-2001 Crop Note Page l

seeding rate by at least 10% when planting no -till. Oats should be planted at 2 bushels/acre and rye at 1-1
1/2 btiSllelslacre. Plant all these small grains at 1-1 1/2" deep. Adequate depth control is essential. Review
the NCSU Official Variety "green book" and information from private companies to select a high yielding
variety with the characteristics needed for your area and conditions. Apply no more than 30 lbs/acre N at
planting. Phosphorus and potash recommended by a soil test can also be applied at this time. The
remaining N should be applied dur'sng the months of ):ebruary-iVlarch.
32 116 5 Database Version 1.06 Date Printed: 07-12-2001 Crop Note Page 3

.o"'oF War�Rp�
r
.sxa�r
December 13, 2004
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
RECEIPT # 7003 1010 0001 2611 4858
Sherwood E.Allcox
S.E.A. Livestock
255 Fork Lake Drive
Clinton, NC 28328
RE: Sludge Survey Testing Dates
Facility # 82-184
Sampson County
Dear Sherwood E.Allcox:
Michael F. Easley. Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E. Director
Division of Water Quality
DENR - FAYE Ul_t .'t OFFICE
The Division of Water Quality (DWQ) received your sludge survey information on
December 13, 2004. With your survey results, you requested that a sludge survey for the lagoon
at the Sam Worthington Farm not be required until 2007. Due to the amount of treatment
volume available, DWQ agrees that a sludge survey is not needed until 2007. The results of the
2007 sludge survey are to be submitted with the Annual Certification Form that will be due on
March 1, 2008.
Thank you for your attention to this matter. If you have any questions, please call me at
[phone].
Sincerely,
Keith Larick
Animal Feeding Operations Unit
cc: File# 82-184
Larry Baxley, Fayetteville Regional Office
!v `hCaroIina
,Xaiura!!y
Aquifer Protection Section 1636 Mail Service Center Raleigh, NC 27699-1636 Phone [phone] Customer Service
Internet: h1tp:flh2o.enr.state.nc.us 2728 Capital Boulevard Raleigh, NC 27604 Fax [phone]
Fax [phone]
An Equal Opportun4ylAfflrmative Action Employer — 50% Recycled110% Post Consumer Paper

December 1, 2006
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Sherwood E Allcox
S.E.A. Livestock
255 Fork Lake Dr
Clinton, NC 28328
Michael F. Easley, Governor
William.G, Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Subject: Application for Renewal of Coverage for Expiring NPDES General Permit
Dear Permittee:
Alan W, Klimek, P.E. Director
Division of Water Quality
RECEIVED
DEC 06 20
W-FAYEIIE UI:REdONALOWE
Your facility is currently approved for operation under one of the Animal Waste Operation NPDES General Permits, which expire on
July 1, 2007. Due to changes in federal rules, facilities that do not discharge nor propose to discharge may choose whether or not to
retain coverage under an NPDES General Permit. Copies of the draft animal waste operation NPDES general permits and the State
Non -Discharge General Permits are available at httpalh2o.enr.state.nc.us/aos/afou/downloads.htm or by writing or calling:
NCDENR — DWQ Animal Feeding Operations Unit
' 1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure your continued coverage under one of these two types of general permits, you must submit an application for permit
cove thivision. Enclosed you will find a `Request for Certificate of Coverage Facility Currently Covered b, a� n Expiring
rage to ,.... e Division.
NPDES _—
General Permit.' The application form must be completed and returned by January 2, 2007. Please note, you must include
two (2) copies of your most recent Waste Utilization Plan with the application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation ofNCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the draft general permits, the enclosed application, or any related matter please feel free to contact the
Animal Feeding Operations Unit staff at 919-733-3221.
Sincerely,
Ted L. Bush, Jr., Chief
Aquifer Protection Section
Enclosures
cc (w/o enclosures): Sampson County Soil and Water Conservation District
Fayetteville Regional Office, Aquifer Protection Section
AFO Unit Central Files - 820184
Premium Standard Farms Of North Carolina Inc
Aquifer Protection Section 1636 Mail Service Center
Internet: wwwmrwaterauality.ore Location: 2728 Capital Boulevard
An Equal Opportunity/Affirmative Action Employer— 50% Recycled110% Post Consumer Paper
Raleigh, NC 27699-1636 Telephone:
Raleigh, NC 27604 Fax l:
Fax 2:
Customer Service:
ON nc Carolina
(919)
[phone]
[phone]
[phone]

State of North Carolina
Department of Environment
and Natural Resources
Michael F. Easley, Governor
William G. Ross Jr., Secretary
Kerr T. Stevens, Director
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Sherwood E Allcox
S.E.A. Livestock
255 Fork Lake Drive
Clinton NC 28328
Dear Sherwood E Allcox:
A" 00
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCE5
April 6, 2001
11
'APR 16 2001
KEJ. 0t"r�31✓._
Subject: Notification for Wettable Acre Determination
Animal Waste Management System
S.E.A. Livestock
Facility Number 82-184
Sampson County
A letter dated January 15, 1999 was sent to advise you about concerns associated with Certified Animal
Waste Management Plans and the method by which the irrigated acres within the plans were calculated. Only
the acres that are wetted can be credited in the waste management plan as receiving waste application. Any
acreage within the plan that can not be reached by waste application equipment can not be used as part of your
plan.
An evaluation by Scott Faircloth on 4/14/99 was made to review the actual number of acres at your
facility that receive animal waste during land application. The evaluation of your facility has yielded one of
the following two results as indicated by the box marked with an "X".
Category 1:
❑ The evaluation of your facility could not be completed due to a lack of information. Please
contact your Technical Specialist to assist in providing Scott Faircloth the necessary
information to potentially exempt your facility from undergoing a complete wettable acre
determination. Please submit this information to Scott Faircloth, at 225 Green Street, Suite
714, Fayetteville, NC 28301, within in 90 days of the receipt of this letter. If you have any
questions please contact Scott Faircloth at [phone]. If within 90 days you are
unable to provide Scott Faircloth with the information you are automatically required
to complete a Wettable Acre Determination as described by Category 2 below, within
180 days of receipt of this letter.
1617 Mail Service Center, Raleigh, North Carolina 27699.1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10%a post -consumer paper

Notification for Wettable Acre Determination
Animal Waste Management System
Page 2
Category 2:
(� Your facility has been identified by the Department of Environment and Natural Resources
as a facility that may have overestimated the number of acres actually receiving animal
waste. Therefore, some or all of your fields may be exceeding the allowable loading rates
set in your Certified Animal Waste Management Plan.
In order to resolve this issue, please contact a designated Technical Specialist to have him
or her conduct a Wettable Acre Determination for your facility. The Technical Specialist must
be one that has been approved by the Soil and Water Conservation Commission to conduct
Wettable Acre Determinations. Many Technical Specialist with the N.C. Cooperative Extension
Service, the Soil and Water Conservation Districts, the Natural Resources Conservation
Service, and the Division of Soil and Water Conservation have received this special
designation. You may also contact a private Technical Specialist who has received this
designation, or a Professional Engineer.
All needed modifications to your Animal Waste Management System must be made and
the Wettable Acres Determination Certification must be returned to DWQ within the next
180 days. If the needed modifications are not made and if the form is not returned within the
required time, DWQ will be forced to take appropriate enforcement actions to bring this facility
into compliance. These actions may include civil penalty assessments, permit revocation,
and/or injunctive relief.
Once a Wettable Acre Determination has been completed, a copy of the attached Wettable
Acre Determination Certification must be submitted to the address listed on the form. Please
note that both the owner and the Technical Specialist must sign the certification. A copy of all
the Wettable Acre Determination documentation that applies to your Waste Utilization Plan
must be kept at your facility. DWQ and the Division of Soil & Water Conservation Staff will
review all documentation during their annual visit of your facility. An additional copy must by
kept on file at the local Soil & Water Conservation District Office. Please note that if you install
or modify your irrigation system, a designated Irrigation Specialist or a Professional Engineer
must also sign the Wettable Acre Determination Certification.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Sonya Avant of our
Central Office staff at [phone] ext. 571.
Sincerely,
Kerr T. Stevens
cc: Fayetteville Regional Office
Sampson County Soil and Water Conservation District
Facility File
Prestage Farms

October 30,2000 RECEIVED
Nov 0 2 2000
Mr. Paul. Rawls,
Water Quality Regional Supervisor
Dear Sir:
In January of this year I changed intergrators from Prestage farms to Dogwood
Farms. Very shortly thereafter, I was contacted by Mr. Bryan Spell who at that
time was employed by Dogwood Farms as Enviromental Spec. He advised me that
he would collect my lagoon samples and figure and complete my pumping records
for $250.00 per year. We agreed on this arrangement, however I offered to
continue to collect the lagoon samples as I had been doing but he insisted that
it was part of the'service he provided.
I requ--,:.,7i red at that time to go over my farm requirements and pumping amounts
pressure, gun cart sp•etsd.,, atil. HQ statedthat: Z. needed to call him set up an appointment.
I repeatedly called, never being able to talk only leaving messages that were never returned.
In my numerous calls -to him I requested that he tell me'what my lagoon samples results
were, so I could calul'ate the amount that I was spraying, otherwise I was spraying blind.
The first time I heard from him was two days.prior to visit from inspector. Mr.Spell called
me and inquired as to location of my pumping records. I advised him that the records were
located at the farm. I also expressed concern and displeasure at his performances and I
told him I was concerned about the amount of nitrogen I had been spraying in the absence
of any samples. He assured me that he had the lagoon results and not to worry about the
rest he could "fix" that.
You can understand my surprize when I read my copies of inspection that stated there was
no lagoon samples and the overspraying on the field.
I immediately contacted Bryan and after several attempts he advised that there was nothing
to worry about that he would take care of it. He stated that he had forgotten to find the
sample results and place them in my book, but he would and return it.
It took two months for him to return my pumping records with the lagoon samples included,
the sample results are attached for your inspection.
I realize that it is my responsibility to see that all aspects of this operation comply
with all General Statutes, and I accept this as such. However I feel that you should be aware
of the reason for these problems.
I have this date discussed this with Mr. Danny Bailey of County Ext. Service, and he has
agreed to meet with me on Nov.7,he has also agreed to supervise my operation and calculate
my pumping recordsin the future.I.will also take my.awn lagoon samples as I was doing prior
to this occurance.

I have also increased the speed of the gun cart on all my spray fields so as to prevent
overspray in the future.
I have also contracted with Mr. Charles Murphy to sprig coastal bermuda hay in my field
#1 in Spring of 2001 to allow more application if it is necessary.
The Deptartment has my full assurance that there will be no reoccurance of these problems
or any others at my farm in the future.
If I may be of further assistance please.
Zt Re rds.
?�
Sherwood E.A11cox.
255 Fork Lake Dr.
Clinton,N.C.28328

l _ ! I.r,. _ 7.. T
_;(}` "I.� it i=i �=:T i-�[i V�r-� 3� ._ i r�,�r. ,_ ! � ._• ...
1919)PHONE 50 2i G'i 0 ri G P I I . U r_ 4 L, P E
---------------------------------------------------------------
Please reu i ew the attached i-! l an crld G,p ; i f (c;i t i ons. wn ref u I IV.
Retain t h P= p 1 5 n f o I` your u s e and r e v u r d s. . It is strong! v
r-
recC!i(mended �t'hai, &Q, your contractor and .the Sa V i Conservat i ort
Service pr'S si.,nnell dry: in agreemenV a_, 'tu how the waste lagoon
is to , be constructed. SCS per,sonpe w,i I. I . meet with all
conc e rkied parties and walk over the site to exp l a i n al I f )ags
and markings. It is impDrtant that everyone understands what is
expected so Lhat f i na I construction meets p I ans and
spec i f i cat i ons and she job can be ce rt i f i ed for payment (if ACP
cost —share is i nvo I ved).
The ped- A i mens i ons and' grades- are the hest est i mate . The
hu i t der or contractor i s respon_+ i b l e for. final I ayout .arid
design pf the pads. SCS personnel will assist in a limited
capacity, -as its major concern is the pr6per design and
constructi on of the waste•, treatment lagoon.
The actuaI amount of material required for pads and dash may
vary- from the est i mates.• The design will attempt to balance
cuts and fills as elate as passible. If addivional material Is
requ i red after construction is complete on the I Agoon, the
contractor and owner will negotiate on the price and Iocation
of the borrow area.
It should be noted that: certification of the lagoon wiiI depend
upon all specifications being met. Import s include
length, width, depth, slopes, -. topsoil placement, correct
elevations (top, bottom, discharge pipes), and seeding.
w ARE CULTURAL WOUR'CES EL+IDERT"? . YES.'
DESIGN REQUIREMENT: 5PA 2S9. cu.ft =21,528-- cu.yds.
ESTIMATE OF EXCAVATION: 074,17j cu.ft-=17,562- cu.yds.
EST IMATE OF PAD: 260,091 c u: f t =9 3 So .. c u- y d s.
ESTIMATE OF DIKE: 79,920 cu.ft =2,9E0 cu.yds.
ESTIMATE OF MATERIAL FOR SANDY —CLAY LINER: — 0 cu.yds
EST I MATS 'OF -TOPSOIL REWIRED: — 340. c u . y d s .
- —..... ... Tota I Excavation =4.7, 562' 0u. yds.
Job Class TV'
Designed 6y ' HERMAN R I GGS -._. 1 3 /25l§2
Date
Design Approval
Date

SOILGONSERVA;tun}cnv rr
SOIL MAP
Owner �HSAME
,TJ00D ALCOX Operator
County -.s AIAPG011 State NORTH GaOLINA
Soil survey sheet (s) or code nos. Aproxirrmate scale
5000 AD00 30DO 2000 1000 0 5000
:+tmen I Df AgrICulture, 1 5 0
a4+ng agencies o.
n 1973 Scale • 1:240�U
;3r;ment of Interior,
5AhhYS011 COUNTY, NORTH (', 4RG1_lNA NO, 16

F-37Maj. mso®momo®MINION MINION MEN m

rqy 1771
�A

SAMPSON COUNTY
NORTH CAROLINA
FRIPMED IT THE
NORTH CAROLINA DEPARTMENT OF TRANSPORTATION
DIVISION OF HIGHWAYS —PLANNING -AND RESEARCH BRANCH
h
IN C00RI1ATl0N WITH THE
U.S. DEPARTMENT OF TRANSPORTATION
Ix
FEDERAL HIGHWAY ADMINISTRATION
SCALE
iI39
I 0 1 7 ] A µUES
M1
o + wul
SCALE FOR E-NLAIIGEmEmTS
i
r
".............
'+e,a
Woywau L!
2.1
ilk
1 1� 1!]L �•°
1tl f� \e
2m�\`
v
9
�G 1Lf!
'Lil
9 1llL 1.941
h
r�
I
aa
41
\`� ,+•
]'1.3
till
1l12
'AP
7
A
SridPA I �
114 ,117E
✓'
'a
D ',,_` f
LL4 •• lia
PA. 1•, li 117E
! �.,7
Ill
+J
:, POP. Ili
v
'•a �-
� • 'P 1.t! SII� lli- ��\ M1,+,.
dr 1f8i
y, 1993. r. ...
.1 if_r
'
}li'-
{
unigm
uLl.L��`:�
Lm
�
i
. �
''� i
I IJi I.1
1 J 1.I11 •� •a .'
ILL 14
h 1isZ
LW
'�
,
�•
a,� l ]s
1711 Ills
LIB- 11u L
�f'
,
11t 111f i
•. �
llb +.9�
+ lam! BLA CR 411
/
LZ
�
( � Ll7!
�
C
t ► M1 C� 1121
Tssd o.}
1L1
I.n � 11)-t
/• �.
L
\
Jim +
im;
All yFti Ii :1;
r-w a,a„�
"�' •L.
POP. Its
1m
p
ims
r
,

( � `)) `�"� _) `� TOMAHAWK, N.
r ` 1 I IAI�HANGI.F.� • 7- �-
II �� Nf-A WIUTE IAKE 15' Q r ``!„ 1•.14 �..J �.. �.
�1�.-,cem 3407B-F3TFa24 �� "Ui''l ��r
�-->--,_ 1986
1 131
PMA 5353 111 NE -SERIES VS42 m
Oro-
r.
57
'� � � �`�, r .`; � � �_ •..; � ., j": {'�J l � _�� � ,rim, � ,.�
IN
a
57
I ;1��1 �.,� J. � D •..,ter , �
ce
ee
ia. Gam ` 1L %
�� r - Cam.,::.

U. S. Department of Agriculture NC-Lh6-34
Soil Conservation Service September 19BO
File Code: 210
HAZARD CLASSIFICATION DATA SHEET FOR DAMS
Landowner SHERWOOD ALCOX County SAMPSON
Community or Group No. Conservation Plan No.
Estimated Depth of Water to Top of Dam Ft. Length of Flood Pool Ft.
Date of Field Hazard Investigation 11/24/92
Evaluation by reach of flood, plain downstream to the point of estimated minor effect
from sudden dam failure.
Est. Elev.:Est. evatzon
Kind of :Improvements: of Breach
Reach: Length: Width: Slope: Land Use Improvements . Above :Floodwater Above
Flood Plain: Flood Plain
Ft. Ft. Ft. Ft.
2 .
Describe potential for loss of life and damage to existing or probable future downstream
improvements from a sudden breach A SUDDEN FAILURE OF STRUCTURE WILL NOT
ENDANGER LIFE OR DAMAGE PUBLIC TRAI,SPORTATION, LAGOON IS LOCATED IN A RURAL AREA.
APPRO. d3000' TO STATE ROAD. APPROX 3001 FROM A TRIB. TO BLACK RIVER.
Hazard Classification of Dam (a, b, c) (see NEM-Part 520.21)Q_, ^
Dam Classification (I, II, III, IV, V)
BY HERMAN RIGGS, SOIL CONS. TECH. Date 11/24/92
name I - (title) -
Concurred By �•C Date // ZSy z—
name 9�m e
NOTE: 1. Instructions on reverse side.
2. Attach additional sheets as needed.

cj44 C,r L1 l;, 4_:LiUrl.� _
:,;-r,4'1`-�'_lfv Da "i .
Dim ;. r.f:r_ T.c, n'ar'e5: re=.i j nr,e (iatIi
l ST AE ADY :_ 7 y.TE L I E WE 1 Gr-iT
a rabJ L:{� � i n I F.
r,n l
0 Head (f iriis,,in9 c,n1 5 ibs-
L, SUWS i{'Flrrnw tr, We�n1 A 4.;S Ibs
C) Head cWean t.c, J feedE:�r
T L; T r` L L; - i �.. ;-., Ci T /�� I A. 1 Y E L S '4' E W tE GH I L W 1
�. Ifiil'JiP'li_lff n'ECitiip' �� "i �;;=F'tTMEi';T ',1DLUME OF L,,GO'L1N
-191"1 1l .)(?
vo I ume = �}9[{�I00 1 b7, SS)LW X TI"'e a �iTi �i i, �r4 i Uflle �� � i �, :1LIr�l
T re.a -Lment 'Vr, I urrie CF/ i b. S LW= 1. U CF/ i b S-�SLW
Vo I ume = 'S9G900 Cub i C f i-
S.
STOPAGE 'VOLUME FOP SLUDGE ACCUMULATION
VC, 1 U m e = 0 out, i c, feet
4. TOTAL DESIGN VOLUME
Inside top: length =:225 feet ; w i dth 2SJ f eet
Top of dike at elevation 56.00 feet
Freeboard 1 f eet S.i de s I apes 3.0; 1 ( i ris i de)
Total design lagoon liquid level at elevation 54.70 feet
Bottom of I agc,on at e I evat i on 44. OU feet
Seasonal high water table elevation 46.00 feet
Total design volume using prismoidaI formula:
S'S END 1 S S/END2 SS/S I DE 1 SS/'END2 LENGTH WIDTH DEPTH
-.0 3.0 3. Q "?.0 317.G 222.2 10.70
AREA OF TOP
LENGTH X WIDTH
317 222 70482 (Area of Tod;)
AREA OF BOTTOM
LENGTH X WIDTH =
25S 158 39974 (Area of Bottom)
AREA OF MIDSECTION
LENGTH X WIDTH X 4
285 190 21£790 (Area of Midsection X 4)
CU. FT. = [Area 1.op+(4?:Area Midsection)+Area Bottom3 X Depth/B
70482 215790 39974 2
VOL. OF LAGIOON AT TOTAL DESIGN LIQUID LEVEL = 583588 GU. FT.

T-.,,'i NR,` P"Y 'c T1=1r;A1iE PECiLI i RED
Drai nags: Area:
Lagoon (tc,p of
Length W:i dtr
C'?C �C"D -4750 Z qua, e Feet
Dui i di rips t_ oof and I of ;.uteri
Length ;, Wi dth
0 C 0 square Feet
TOTAL DA 74750 Square Feet
7es i gn tern porary storage 'L:o he
A. Volume of waste produced
1S0 days.
Approximate da.i IV production of manure in CF/LB SSLW 0.00136
Vr., Iume =-�,96900 Lbs. SS'W X,' CF :)f waste/ I b/day / 1 0
Volume = °7161 CuL,ic feet.
B. Volume of wash water
Th i s i e - Fhe amount of f resh water used for washing f I oors or
volume of fresh water used for a flush system. Flush systems
that recirculate the lagoon water are accounted for in 5A.
VoIume = 0 GaIIonsf'day X 180 days storage/7.46
gallons per CF
Volume = 0 Cubic feet
C. Vo I urne cif ra i nfa I I i n excess of evapo rat i on
Use period of time when rainfalI exceeds evaporation by
I arcgest @,mount.
160 days excess rainfall — 7.0 inches
Volume = 7.0 Inches X DA / 12 inches per foot
Volume = 43604.167 Cubic feet
D. Volume of 25 year — 24 hour storm
Volume = 7.0 inches / 12 inches per foot X DA
Volume = 43604 Cubic feet
TOTAL I';ECIUIPED TEMPORARY ''STORAGE
5A.
97161
Cubic
feet
56.
0
Cubic
feet
5C.
43604
Cubic
feet
5D.
43604
Cubic
feet
TUT L 184S69 Cubic feet

a. SUMMARY
Tota i requ i red vo i ume =
5812119
Cubic feet
Total design
vo l ome
ays I .=
5S35 8
Cubic feet
Min. regrd. trtmnt.
vo I . p I u_s
sludge
accum.=
296900
Cu. Ft.
At e l ev.
52.00
Ft; Vol=
404848
Cubic feet
:end pumping)
Total deG i gn
vo I ume
less 25yr-24hr
storm
=
519984
Cu. Ft.
At elev.
54.00
Ft; Vol=
515040
Cubic feet
(start
pumping)
Seasonal high
water
table elevation
is
46.00 Feet, which
must
be lower Kan
the elevation
of
top of
treatment
volume
51.00
DESIGNED BY: APPROVED BY:
---------_640 - - - - - '-°--P�-.-----------ar•
DATE: 1 1�_�-5 _ 92. DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
ADDITIONAL NOTES:

Brock Equipment Co,
PO Box 100
BAILEY, N.C. 27807
Phone [phone]
Fax [phone]
6-29-99
This irrigation system was designed for Sherwood Allcox by Shane 'Ward of Brock
Equipment Co.
A scaled drawing, required calculations, and required specifications on pipe and equipment
are included.
The following buffers were maintained on this farm:
25 feet from ditch
25 feet from property lines
75 feet from property lines with occupied dwelling
75 feet from surface water and perennial streams
100 feet from well
200 feet from residence
All comments and recommendations are appreciated.
Thank you,
mot,
Shane Ward
'5z;;dlx� 1--14
Lee Brock, Technical Specialist

r
CRLr•. L+x+ �; 71� � 1
,../r• .L•r �'kx.,5"',Jr`,It.> ;+,�•�111°f :F iw M'l. �]05.. . • ~'-;sl''�l`�•
1 7 �� F i✓y , i y Tr r% 1 1 r' Y' If f
TT:
A 4 'i' 11 , •. � A � ti�
SHERwooDALLCOX
a•, s.
rf7,'tr .ld� 1. '� c_ I ' if ,i cif ' ?' • r, ,
nirmiBmaim
prt; `5r •'' %ti 'i �'S� \ r. ; r.� 11 •) 5 \ `.
ALumPipe
21, 201) PSI PVC
rt• ':r` ! 4'' 1'{-..r .IFS': .t -

FIELD SPECIFICA TIONS
The lowest maximum application rate (inches per hour) = .6
The lowest maximum application amount (inches per irrigation cycle) = .65
Amount of Nitrogen produced per year for application = 6,762 lbs.
"This plan effectively wets 11.26 acres in Field #1 @ 210 lbs. per
acre for a total of 2,364.6 lbs.
"This plan effectively wets 4.06 acres in Field 42 @ 325 lbs. per
acre for a total of 1,319.5 lbs.
"This plan effectively wets 11.21 acres in Field 43 @ 275 lbs. per
acre for a total of 3,082.8 lbs.
2,364.6
1,319.5
+3,082.8
6,766.9 lbs.
This information was provided by the waste utilization plan.

Traveling Irrigation Gun Settings
Travel speed = 1.9 fpm or 22 ipm
Application rate = .55 iph
Lane spacing = 225'
Netted diameter = 300'
Gun make and size = Nelson 100
Ring size = .89"
Operating pressure at gun = 80 psi
Operating pressure at reel = 126 psi
Operating pressure at pump =152 psi
Arc pattern = 1801
Flow rate of sprinkler = 163 gpm
Pump power requirement (bhp) = 27
Total acres covered (effective) = 26.53
Traveler make and model = Cadman 2625
Hose length = 900'
Hose diameter (ID) = 2.625"
Speed compensation = Mechanical

Hard Hose
Traveling G&_ _ System Wettable Acres
"
Farm
4 _
Irrigation System Designation: New t Expanded
Wetted Diameter:
300
Spacing: 250 (70%)
Pull #
Leop-th
Width
Acres Middle Portion
Start End Stop
End
Acres of Pull
1
860
247.5
4.89
.75
.00
5.63
2
860
247.5
4.89
.75
.00
5.63
3
230
247.5
1.31
.75
.00
2.06
4
220
247.5
1.25
.75
.00
2.00
5
860
247.5
4.89
.75
.00
5.63
6
850
247.5
4.93
.75
.00
5.58
Total Acres:
EE75
Exterior Start = .75
Facility Repmsentative:
Tecboical Specialist: M. Lee Brock Signature: Date:
26.53

Wettable Acres Determination Certification
Name of Facility: . �,y�� �yr. rL' Facility Number: ��- f 9�
Owner(s) Name: -�lerl.!ao,W Phone No:f1/O> 5—f.-2 �
Mailing Address,��5
By signing this form, the facility owner and Technical Specialist acknowledge the completion of the
Wettable Acres Determination. All necessary Wettable Acre Determination Field Data Sheets and
calculations were completed to conduct a Wettable Acre Determination. The facility's Waste
Utilization Plan has been amended as necessary to reflect actual wetted acreage. A copy of all
worksheets, calculations, and other Wettable Acres Determination documents, along with the
applicable Waste Utilization Plan and Wettable Acre Determination Certification will be filed with
the local Soil and Water Conservation District. A copy will also be kept on site with the Certified
Animal Waste Management Plan. Any future modifications must be approved by a technical
specialist and filed with the Soil and Water Conservation District prior to implementation. If any
modifications to the existing irrigation system or any new irrigation equipment was required to
adequately address the waste management needs of this facility, an Irrigation Specialist or
Professional Engineer has certified the design and installation below.
.1
Owner Name: y += Li
Owner Signature:
Technical Specialist Name:
Technical Specialist Signature:
Date:
ate: .a 3
U assisted by an Irrigation Specialist or Professional Engineer please read and sign below:
Animal waste application equipment has been designed or modified to apply waste as necessary to
accommodate the waste management plan and according to NRCS Standards. Animal waste
application equipment has been installed according to NRCS Standards and is ready for use.
Irrigation Specialist/PE Name.
Irrigation Specialist/PE Signature: Date:
Submit this form to:
Attn: Sonya Avant
Non -Discharge Compliance Unit
Division of Water Quality
1617 Mail Service Center
Raleigh. NC 27699-1617
WA,DC -' 7199

Swine Farm Waste Management Odor Control Checklist
�o11 r1't:
~I':utt+.lc:ul_
(pause
11i111's in !ti1inimi-t : 041111-
`Sill.' S1Yt: t'If Ye III Ct lt't'S -
a
tilvinC pfuduGloil
vegetative or WQodvd hllffers; phJ
13+rL i)F Fjl/t•i� C% ���f�,1./ i eta
at/Reconlillentled hest nlanagenteill practices;
R"' Gonditldgmellt and common sense
Aminai holy sulfacci &
MAY mallilre-Crlvered aninials
f1 hry llonrs
Wd llii11111re-L'0VUCd flliol'S
fr Sltllted llonrs;
FJ Walerers located over slotled floors;
Cl Feeders at high r-nd of solitl floors;
rl Scrape nianure hnildup f oin floors;
n llntlerflnor veluilatinli For drying
`
--td.1sWIL: Ci111LLl1011 lily +
I
IIrine;
w"'i I y I 1 ,
l+r 1'rt:i 11CIIt n1i1111YIC rLI130VJi ll IllulY, lil rt:cl+ar ��,
I-ac'At4P�1y n
1
•
I':1l'lla! nliCrllhiA &CO11111t1Sil+tlll
or scrape;
n 1I11(lel'lloar velltitalliill
�f411lii.iiYitlt «�l:ul�l I.1nS •
vl,l,liii,: gaSCS;
fzl" Fan 111aintellance; �l �Ta
rnlar-- J FY3-9-10, C)i4t '
I lust
[T� Efficient air ntnvemenl
lu,l,tut Sul l-dCC] • DliS1
l 1u:,lt t.�ttl-i — Agilaii;in of recycled lagnnn
li,luid While ranks are filling
!'In,h .tile � s ---- Agil;llitui during ivaslew.uGr
GH1L'C}'ii llCl'
-k`it I,-i It,u�� kn,iuls Agitation of recycled Lagoon
liquid while pits are filling
I ABilalion thiring sump lauk
filling and drinvilown
I li+t.l,ll: Ilfaill CAILLllllti • Agitalitln during; ivaslCwalCr
ul' tI1llLEltln IIU+CS CiHIVe}'iliii4
Washduwll hC1WCCll graupS of aniuillls;
Cl Feed additives;
fl Fectlur Cover's;
fR" FCcll delivery downslinlil extenders 11l fccder
Covers
Cl Flush Bulk Covers;
n I-xiond fill links to near hnutmi (if wAs With
anli-siplinn velus
n underfloor flush With 1111der11001- ventilation
Cl Ex14:1111 rceltarge lines it) ucar himmil of 1;ils
wilh anti-siplititl veils
Cl Skimp tank covers
Igo Ctivers
kLo TV5 D N G A/ }tom-: ,'
Anil W - liovvinber 11, 1996, Page 3

w 5Ru1'CC
Cause
BMPs to Minimize 041or
- -- -- Site SlICLil1C I'1'aCIICcS
Intl .11 dl 11i1111 fi 5 :11
Agllalion during wastewater
C1
Extend discharge point of pipes undemea111
la�t,oii
conveyance
lagoon liquid level
l.agoull SlIffaCLS
a Volatile gm emissions;
❑
Proper lagoon liquid capacity;
• Biological mixing;
[1
Correct lagoon startup procedures;
• Agitation
rl
Mitlinium surface area-lo-volume ratio;
CI
Minimum agitation when.ptimping;
Cl
Mechanical aeration;
fl
11mvcn biological additives
ILIil;:klium sllriIIIAL r
I ligh pressure agitakion;
ilir
Irrigate on dry Clays wish little or tin wind;
ia,t f.a �-� ck e,'x &,,v 0
T
nn�elt'
. Wind kirifl
C1
Minimum re.eommendetl Operating ressme;
Lcm� r
L-1
Pump intake near lagoon liquid surface;
❑
Pump from second -stage lagoon
51111.kLc t:ukl: ur IGIsin
• Pw ial micnibial decomposition;
r-1
llnitont rlr 11101evel IoadiUg;
Sill l:It:i.
. Mixing while: tilling;
❑
"Tank covers;
• Agllalllln When C11111tylnb
❑
Basin surface orals Of solids;
n
Proven blolOglCal additives Or OXiI MILS
-Szldin� basin Snrl:IcC
• I'arltal Iiki, R[Ohlal de(:01111)Il5kli011;
❑
F-MC1111 llranlllilIC 01111LAS Underlteilltk hilitd
• Mixiog while filling;
level;
Agitation when emptying
❑
Remove settled solids regularly
t.1:IIInIc, shu'ry 01
Agitaliolk when 5prcaililig;
�n
Soil illjeclion Of slurrylsludgcs;
-- ---- -
spwiidcr oLltlL:ts
. Volatile gas emissions
❑
Wasll.residltal manure from spreader alter use;
❑
Proven biological additives nr oxidants
t filcol'ered In:uulre
Volatile gas emissions while
❑
Soil injection of slurry/sludges
r luny iIr skudae 011 Cleft
drying
❑
Soil incorporation wilhin 48 hrs.;
]ill k�IIL�
f3
Spread in thin uniform layers fur rllpid 1lrying-,
❑
Proven biological additives ar Oxidants
Ficatl ,inillk:kls
Carcass ducnn)pnsilion
f'i)rnper disposition of carcasses .
5��� -
—C)1-1, :1llnll:tl iT.11uS:tl
Carcass deetimposltlon
❑
COI111l11'tC COVerllig ul C8rCa55es lli I)ul'1al 1111s;
t
I'`'
❑-�yy
Proper Incation/ennstruelion ofdi-sposal Hits
l;
lmconll) CIL: cumhnslinu
n
Scemlldilry slack hurners
antler l 1, kt)L>n, !'agc4

S,ulrce
Cause
Iih1PS l0 117luinli•[c (blur
SiIC SpCCUIC l'raCtiecS
S1;1:Milli; %VJiL:r arll►Ind
• Improper drainage;
_ Gradr and landscape such that water rlfain5
1
iacdiiie'
0 Micrallial decomposition of away
from facilities
organic matter
P.1�1nurC lrat:l:Ctl ouw
. Poorly maimained access roads
I:ann access foal lnaimenaucC
Initfllc roinlj 1 ilm farm
access
AlMilianat Infllnnatiou :
SIVilie Mlallnrc Mlarlal;Cuicnl ; MOO ItnICMIP f aCkcl
StrillL: I'r1)dL1Clll]n I•ann POWntiat Odaf SOUMCS and Itl:ltledies ; FBAE fact Shed
SwinC 1'nnlnCtiun Facility Manure M9anagemenl: Pit Itecllarge - Lagoon Treatment ; FBA& 128-88
S%Vine PraduCliull Facility Ml:lnnrC Management: Underfloor flush - Lagoon Tfcattnent ; FRAF 129-98
1-agtlou DCS01 and Management for Livestock Manure Treatment anti Storage ; I;IIAI's IM-83
C:diluation ofMaitme and Wastewater Applicalinn I:Ruipmcnl; FBAF fact Shed
l.,I1111o111ng ( 1LAS Irillll SwinC lltllldingS ; I'll1-33
1:nvir+,llnlcnl:fl Assarance Program ; NI111C Mlannal
tlllli„ns f11r Mtanat Ilig ()tla( ; a report fraln 111e Swine Odor Task: Force
iluis,lncC C:lmccrns in Animist Kiantlrc Management: Odors anti flies ; 11I10107, 1995 Conference Proceedings
APIs W - [41-111-1- 11, 1996, P,11;e 5
AvaiLlI)IL: Ilnm :
NCSt 1, Colmly I:xlensiull G:fucr
NCStI - ItA1:
NCSI I - IIAI:
NCS11 - BAV
NCSI I - IIAill.
NCS11 - IIA1:
NCS11 - Swine 1:xlC11sion
NC folk ProilucCn Assoc
14C:St1 Agri Cn11ui1tlnit:ini(lllS
Florida C00j)Cfa1ivC VXICnSiOR

Insect Control Checklist for
i�
i
I
Animal 6peratlons
ti,LLlh'c is Cause IlE1 11's to CW)11'UI 1IIScc15 Site Specific III-acilecs
Liquid Sysleuls
1:111AI (ilaticis Accumulation of snlllls ❑ I'Illsll system Is LICSib'IMI and operilled
sufficiently to remove accnnulliatctl solids from
gutters as designed. `
n- Remove bridging of acclamulaled smiths al
discharge
Liigoons and ["IS CI LISIVd Solids C) Maintain lagoons, sculin6 basins aiul I)ils where
pest breeding is apparent to minimize the
c(nsling of solids to a depth of uo more than 6 -
a inches over more than 30% of snirlace.
I:rccs�iv� VugL:llli%'e Dccuyiilg vegOaliurl fii: hMailhlairh vegetative control along hanks of l` �?v EGI� /s�� � Ly Q,
c ;i{�tcili lagoons and other inlpoundnlents to prevent
accwnulation of decaying vegetati�',,u matter
along %VaICr'S Cllge Oil illllhnlindnlClll'S petimcier.
I
_ my Systems =,
l:cc,lCl:� Feed Spillage - --- — -- - -- ------
1'CCd ShulaL.L: Accumulations of foil rl:Siiiucs
ITT 1)esiglh, operide and maintain feed �ysteu►S (u.g.,
blinkers and Irolaglhs) it) minimize Ilse
acclanlillaiion ofdi'cihying Wasiage.!I
fV—cleau up spillage oil a routine basis (e.g., 7 - 10
day interval during summer; 15-3(l slay interval
daring winter)- I
hY ItedUCC Innisllire aCCIIIII11blin11 williin null
aroailid iillnlcllGae pCrilncler (it lccd slot age
areas by ilhsurilig drainage away liiuil site
and/nr providing adehluale contaiuliWILL (e.g..
covered hin for brewer's grain mid Similar hit;la
I
nhoisture grain prothicls).
Inspect liar and remove or break uplaceuiuulaiu+l
solids in IiNcr strips around feed slorage as
needed.
I
V r��J

Mortality Management Methods
(check which menccd(:s) are beini7 implemented)
�.! Burial three feet beneath the surface of the ground within '-u hours art,-r
knowledze of the death. The bumal must be at least 300 fee: from a tio..'vinla
stream or public body of *xater. v
�1Re^dz,in? at a rendering plant licensed under C.S. 1 �6-; 63.7
Comple:e incineration
❑ In the case of dead poultr;J only, piacin� in a disposal pit of a size and design
approved by the Department of Agriculture
:.t Anv method %%tic , in the prcfessionai opinion of the State Vete.�r,a^:an wouid
mAe possible the salvage of part of a dead animal's value ,vitb.out endangering
human or animal health. (Wriuen approv-al of the Scare Ve.e:irar:an must be
attached)

0P[RATiON & NWN I t-.NANCE PLAN
Proper lagoon liquid management should be a year-round priority. It is especially
important to rnar�,age levels so ,hat you do not have ;problems during extended rainy and
.vet periods,
Maximum storm capa6ty should be avadahle.in the iagoon for periods when, the
receiving crop is dormant.isuch as wintertime for berrnuclagrass; or when there are
extended rainy spells such as the thunderstorm season in the summertime. This means
that at the first signs of.plant gromh in the later winter/eaHv spring, irrigation according try
a farm waste management plan should be done whenever the land is dry enough ttr
receive lagoon liquid. This will make stcraae ;pace available in the lagoon for future wet
periods. In the late summer/early gall the lagoon should be pumped down to the low
marker (see Figure 2-1) to allow for winter storage. Every effort shoud be made to
maintain the lagoon close to the minimum liquid level as long as the weather and waste
utilization plan wi}l allow it.
',Naiting until the lagdon has reached its maximum storage capacii-y before starting tc
irrigate does not leave room for storing excess water during extended v.et periods.
Overflow from the lagoon for any reason except a 75-year, 24-hour storm is a violation of
state law and subject to penalty action.
The routine maintenance of a lagoon involves the following:
Maintenance of a vegetative cover for the darn.
Fescue or common bermudagrass are the most common vegetative
covers. The vegetation should be fertilized each year; if needed, to
maintain a vigorous stand. The amount of fertilizer applied should be
based on a soils test, but in the event that it is not practical' to obtain
a soils test each year, the lagoon embankment and surrounding areas
should be fertilized with 800 pounds per acre of 10-10-10, or
equivalent.
Brush and trees on the embankment must be controlled. This may be
done by mowing, spraying, grazing, chopping, or a combination of
these practices. This should be done at least once a year and '
possibly twice in years that weather conditions are favorable for
heavy vegetative growth.
NOTE: If vegetation is cortrralled by spraying, the herb tide .,7,ust not be allowed to enter
the lagoon water. Such chemicals could harm the bacteria in the lagoon that are treating
the waste.
Maintenance inspections of the entire lagoon should be made during the initial tilling of
the lagoon and at least monthly and after major rainfall and storm events. Items to be
ci eeked should include, as a minimurn, the following:
',,`Jaste Inlet Pipes, Recyckng Pipes, and Oveiiiow Pipes --look for;
1 . Separation of Joints
2. cracl<5 or breaks
accumulation of salts or minHra!s
-L (1VNr3ii l:ondit!(n of pi; 's

Lagoon surface--fo ak tor:
9 , undesirable vegetative grqwth
2. floating or lodged dehris
Embankment ---look for;
1. settlement, cracking, or "jug" n..sles
? side slope stabjl&"—SiuUrnps 01'
3. we; or damp areas on the back slope
-4. erosion due to `acid cal' vegetation or as a resit of wave action
5. rodent damage
Larger lagoons may be subject to liner damage due to wave actor caused by strong
,,,vinds. These waves can erode the lagoon sidewalls, thereby weakening the lagoon dam.
A gacd stand of vegetation will' reduce the potential damage cause* by wave action. If
wave action causes serious damage to a lagoon sidewall, baffles in the lagoon may be
used to reduce the wave impacts. -
An,,l of these features could lead to erosion arrd weakenirr, of ,ne lam. if your lagoon ,has
any cf tnese features, you should call an appropriate expert f.-.mikar with design and
cc^5truction of waste lagoons. You may need to provide a temporary fix if there is a threat
of a waste discharge. However, a permanent solution should be reviewed by the
technical expert. Any digging into a lagoon dam with heavy equipment is a serious
undertaking with potentially serious consequences and should not be conducted unless
recommended by an appropriate technical expert.
Transfer Pumps —check for proper operation of:
1. recycling pumps
Z. irrigation pumps
Check for leaks, loose sittings, and overall pump operation. An unusually loud or grinding
noise, or a large amount of vibration, may indicate that the pump is in need or repair or
replacement.
NOTE: Purnping systems should be inspected and operated frequently enough so that you
are not completely "surprised" by equipment failure. You should perform your pumping
system maintenance at a time when your lagoon is at its low level. This wtll allow some
safety time should major repairs be required. Havinga nearly full lagoon is not the time
to think about switching, repairing , or borrowing pumps. Probably, if your lagoon is full,
your neighbor's lagoon is Cull also. You should consider maintairi^g an inventory cn spare
parrs or pumps.
Surface 'yvater diversion features are designed to Carr!., aU surface
drainage waters (such as rainfall runoff, roof drainage, gutter outlets,
and parking iot runoff) away from your lagoon and other waste
treatment or storage structures. The only water that should be
coming from your lagoon is that which comes fron- your flushing
rwa5'hing) system pipes and the rainfall that hits the ;agocn directly.
You should inspR� your diversion system for the iollo ving:
1. adeq,;, to vegetation
Z, diversion capacity

identi(ies; problerns should be coFrected, prornp,ly. I; is a�v�sable to ir4pect your system
during or immediatei), following a hea,.-f rain. If r@,4snIC3i assistance is needed t,
determine proper soiunons, consult wr}h appropriate experts,
You should reco; d the level of the lagoon just prior to when rain is predicted, and than
retard the level again a to b hours after the rain (assurni e5 there is no pumping), This witl
give you an idea of how much your i2goc,n Tavel 1..ili ri.5e 'with a r_er;ain rainfall arno-nt
(you must also be recording your rainfall hor',his to wren,;, Krov-,Iri� `.~is should ',elp in
planning irrigation applicatsons and storage. If your lagoon rises excessively, you may .
have an inflow problem from a surface water diversion or there may he seepage into the
lagoon from the surrounding lard.
Lagoon Operation
Startup.
l . Immediately after construction establish a complete Tod cover an bare s-od
sun`aces to avoid eres;or'-
2. Fiji new lagoon design treatsmiert volume at least half full of water before
waste loading begins, taking'care not to erode lining or bank slopes.
3. Drainpipes into the lagoon should have a flexible pipe extender on the
end of the pipe to discharge near the bottom of the lagoon during initial
filling or another means of slowing the incoming water to avoid erosion of
the lining.
4. When possible, begin loading new lagoons in the spring to maximize
bacterial estabiishment.(due to warmer weather).
5, it is recommended that a new lagoon be seeded with sludge from a healthy
working swine lagoon in the amount of 0.25 percent of the full lagoon
I'iquid volume. This seeding should occour at least two weeks prior to the
addition of wastewater.
6. Maintain a periodic check on the lagoon liquid pH. if the pH fails below
7.0, add agricultural lirne at the rate of 1 pound per '300 cubic feet of
lagoon liquid volume until the pH rises above 7.0. Optimum lagoon liquid
pH is between 7.5 and 8.0.
7. A dark roior; lack of bubbling; am-, excessive Fodor signals inadequate
biological activity. Consultation with a technical speciaiist is recommended
if these conditions occur for prolonged periods, especially during the warm
season.
Loading:
The more trequer'It y and regular".,, ' at 'Nei SteW;U; er is adra',1 io ra !,igocin, th.o Vetter the
lagoon Yviii function. flush s%sterls t at ,vh wvaste into the lagoon several times Cully are
optimum for treatment, Pit recharge systerns, in which one or mnre y kiiidlings are drained
and recharged �a,., rJay, ak5r

practiceb gilding water usage and
spiliage ;corn leaking v:a erers,'broken pipes and wa5hdown through
proper rnamteriance arld water conservation.
iinlrnlZ!? feE!d 'vvastage aria spillage by keeping tpedPfS adj�lStpd. This
V.,iii red U: e the arriournt or s6!rts entering the lagoon
Management:
Maintain lagoon !squid level between the permarennt storage level and
the full temporary storage le".el.
Place visible markers or stakes on the la.goon bank to show the
minimum liquid level and the,maximumliauid lever (Figure 2-1).
Start irrigating at the earliest possible date in the spring based on
nutrient requirements and soil moisture so that temporary storage
.vill he maximized for the summer thunderstorm season. Similarly,
irrigate in the late summeriearly fall to provide maximum lagoon
storage for the winter.
i he lagoon liquid leve? -should never be closer than 1 Toot to the lowest
point of the darn or en —ankment.
Do not pump the lagoon liquid level lower that the permanent storage
level unless you are removing Mudge.
Locate float pump intakes approximately 18 inches underneath the liquid
Surface and as far away from the drainpipe inlets as possible.
Prevent additions of bedding materials, long-stemmed forage or vegetation,
molded feed, plastic syringes, or other foreign materials into the lagoon.
Frequentlyremove solids from catch basins at end of confinement houses or
wherever they are installed.
!Maintain strict vegetatic�n, rodent, and varmint ccntroi near las00 n edges.
Dry not allow trees or large bushes to gro,,,%, or, lagoon darn or embankment.
Remove sludge from the lagoon either when the sludge storage capacity is
full or before it fills Si) percent or the permanent storage volume.
If animal producticn is tc be terminated, the owner is responsible for
obtaining and impiernsting a closure pan to eiiminate the possibility of a
poly=tent d;schar-e.
Sludge Removal:
Rate Of 1,Ag l slUdZe blli dU,-) roan he re~tjc d by:

proper lagoon siring,
niechariical 5oiids separation of flushed waste,
gravity settling of flushed waste solids in an ap.prnpriateiv de5lgned basin, or
mlrlrm,zing frec-d `P,+%iic3 !? and 5pll{age.
0
Lagoon sludge that is removed ann�iatly rather than stared long ;¢rm will:
.1 have more nutrients,
have more odor, and
require more land tc properly use the nutrients.
Removal techniques:
Hine a custom applicator. -
dviix the sludge and lagoon liquid with a chopper.agi-atcr ir�npeller
pump th-ough large -bore sprinkler irriga'ic,n system onto nearby crr Aland,
arld soil Incorporate.
Dewater the upper part of lagoon by irrigation onto nearby cropiand or
forageland; mix remaining sludge; pump into liquid sludge applicator; haul
and spread onto cropiand or foragelard; and soh incorporate.
Dewater the upper part of lagoon by irrigation onto nearby cropland or
forageland; dredge sludge from lagoon with dragline or sludge barge; berm
an area beside lagoon to receive the sludge so that liquids can drain back
into lagoon; allow sludge to dewater; haul and spread with manure spreader
onto cropland or forageland; and soil incorporate.
Regardless of the method, you must have the sludge material analyzed for waste
constituents just as you would your lagoon water. The sludge will contain different
nutrient and metal values from the liquid. The application of the sludge to fields will be
limited by these nutrients as well as any previous waste applications to that fie16 and crop
.requirement. Waste application rates will be d15CU55ed in detail in Chapter 3.
When removing sludge, you must also pay attention to the liner to prevent damage. Clc5e
attention by the pumper or dragline operator will ensure that the lag on liner remains
intact. 1' you see soil material or the syrthet;c finer material being cii'swrbed, vr)u =hou!d
stop the activity immediately anti not re Jme :.intll you are 5ure "at the shjcU e flan be
removed without liner infury, If the liner is damaged it crust be repaired as soon a=
possible.
Sludge removed from the lagoon has a muc.- higher phosphorus and healry metal content
`han liquid, Because of this it should probably e applied to lard viith low phosphorus
and metal levels, as indicated by a soil test, and incorporated to reduce the :hance of
erosion, ,Note that if the sludge is applied to f elds with very high ;c{i-test phcsp�ores, it
should be applied only at rates equal to the crop removal of phr,�-nhorL;s, As with other
wastes, always have your lagoon anal :,zed for its nutrient vaj'.ie,
tie applicatic,n of sludge will increase the amoiint of r,C{or at the ,paste ap�lic:ation Cite.
.- tva precaution shcu!d be used to ObSerre the win, direction and ether conditions which
(7,ould increase the concern of neighbors.

Possible Causes of Lagoon Failure
La�con failures result in the unp!anned discharge of wastewater from the str:c�ure, Types
of failures include leakage through the bottom or sides, rnrerscpping, and 'Inreacn of the
darn, Azisu'7,ing proper GesEvp ar-d V7e. G's�'nPr hay the responsNk,,`f for
ensuring structure safety. Items which may iead to ;agoon failures include:
modification or' the lagoon structure —an example is tha placement of a nioe
in the clam without prooer design and constructicr. (Consult an expert in
lagoon de,51`gn before placing any pipes in }arns,)
Lagocn liquid levels —high levers are a _afer7' risk.
Failure -to inspect and maintain :he dam.
Excess surface ':ater Rowing Into the Iaocn ..
Linar int ,,rity---protect from ; et p;pe scouring, darnage during sludge
removal, or rupC.:re from lowering lagoon liquid level E�elow groundwater
table.
NOTE: if lagoon water i5 allowed to overtop the dam, the moving water will soon cause
gullies tc form in the dam. Once this damage starts, it can quickly cause a large discharge
of wastewater and possible dam failure.
0-1

r
State of North Carolina
Department of Environment
and Natural Resources RECEIVE[)Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E.,
Sherwood E. Allcox
S.E.A. Livestock
255 Fork Lake Drive
Clinton NC 28328
Dear Sherwood E. Allcox:
C C r U � 1998
Direct Y�EVILLE
I EG. OFFICE
October 2, 1998
1 • •
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Certificate of Coverage No. AWS820184
S.E.A. Livestock
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
In accordance with your application received on August 25, 1998, we are forwarding this
Certificate of Coverage (COC) issued to Sherwood E Allcox, authorizing the operation of the subject
animal waste collection, treatment, storage and land application system in accordance with General
Permit AWGI00000. This approval shall consist of the operation of this system including, but not
limited to, the management of animal waste from the S.E.A. Livestock Farm, located in Sampson
County, with an animal capacity of no greater than 2940 Feeder to Finish and the application to land as
specified in the Certified Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations
as specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General
Permit or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS
143-215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This
request shall be made within 30 days of notification by the Division.
This COC is not automatically transferable. A name/ownership change application must be
submitted to the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the
right to apply for an individual non -discharge permit by contacting the engineer listed below for
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Certificate of Coverage AWS820184
S.E.A. Livestock
Page 2
)A ,
information on this process. Unless such a request is made within 30 days, this COC shall be final and
binding.
w
The subject farm is located in the Fayetteville Regional Office. The Regional Office Water
Quality Staff may be reached at [phone]. If you need additional information concerning this
COC or the General Permit, please contact JR Joshi at [phone] ext. 363.
Sincerely
A. Preston Howard, Jr., P.E.
cc: (Certificate of Coverage only for all cc's)
Sampson County Health Department
Fayetteville Regional Office, Water Quality Section
Sampson County Soil and Water Conservation District
Permit File
i

r
Producer:
Location:
Telephone:
Type Operation:
Number of Animals:
(Design capacity)
STORAGE STRUCTURE:
APPLICATION METHOD:
p( % �%gal 0-1�b
ANIMAL WASTE UTILIZATION PLAN
SHERWOOD ALLCOX
255 FORK LAKE DR.
CLINTON NC 28328
[phone]
WAS RQ Ai yvED
s'C"'.
AUG 2 S 1996
Nan•p�,��h�,�e Aemrii�n�
Existing Feeder to Finish Swine
2940.00 hogs
Anaerobic Waste Treatment Lagoon
Irrigation
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops
in the fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
I. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply
more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall be applied to land eroding at less than
5 tons per acre per year. Waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. Do not,apply waste on saturated soils, when it is raining,
or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed
under DWQ regulations.
Page: 1

ANIMAL WASTE UTILIZATION PLAN
5. Wind conditions should also be considered to avoid drift and
downwind odor problems.
6. To maximize the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more than 30
days prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. If
you choose to change methods in the future, you need to revise this
plan. Nutrient levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from your
waste management facility. In some cases you may want to have plant
analysis made, which could allow additional waste to be applied.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
This waste utilization plan, if carried out, meets the requirements
for compliance with 15A NCAC 2H .0217 adopted by the Environmental
Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tone, etc.)
2940 hogs x 1.9 tons waste/hogs/year = 5586 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
2940 hogs x 2.3 lbs PAN/hogs/year = 6762 lbs. PAN/year
Applying the above amount of waste is a big job. You should plan time
and have appropriate equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
Page: 2

■
'w ANIMAL WASTE UTILIZATION PLAN
TABLE 1: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
-------
APPLY
RESID.
APPLIC
METH
N
TIME
6454
1
GoA
TA_
1
110
0
1a.75
1182.5
I
APR - JUL
6454
l�A
Q --710.75
F I
�1
1100
SEP-APR
6454
2
BH
5.5
0
1Wa13
I
1275
14.33
�1190.75
MAR-OCT
6454
SG
1
Q
216.5-
1-2
I
150
14.33
SEP-MAY
6454
3
BH
4.5
0
�]BoB
T
1225
�13.1812965.5
MAR-OCT
6454
SG
1
0
�_3
I
150
113.181659
SEP-MAY
END
I
TOTAL17289.25
- Indicates that this field is being overseeded (i.e. interplanted)
or winter annuals follow summer annuals.
NOTE: The applicator is cautioned that P and K may be over applied
while meeting the N requirements. In the future, regulations may
require farmers in some parts of North Carolina to have a
nutrient management plan that addresses all nutrients. This plan
only addresses nitrogen.
Page: 3

14- ANIMAL WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
See required specification 2.)
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
-------
APPLY
RESID.
APPLIC
METH
N
TIME
END
TOTAL 10
Indicates that this field is being overseeded (i.e, interplanted) or
winter annuals follow summer annuals.
In interplanted fields (i.e. small grain, etc, interseeded
in bermudagrass), forage must be removed through grazing,
hay and/or silage. Where grazing, plants should be grazed
when they reach a height of six to nine inches. Cattle
should be removed when plants are grazed to a height of four
inches. In fields where small grain, etc, is to be' removed
for hay or silage, care should be exercised not to let small
grain to reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too
high and this will definitely interfere with stand of
bermudagrass. This loss of stand will result in reduced
yields and less nitrogen being utilized. Rather than
cutting small grain for hay or silage just before heading as
is the normal situation, you are encouraged to cut the small
grain earlier. You may want to consider harvesting hay or
silage two to three times during the season, depending on
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late
September or early October. Drilling is recommended over
broadcasting. Sermudagrass should be grazed or mowed to a
height of about two inches before drilling for best results.
Caution must be exercised in grazing or haying summer
annuals under stressed conditions. Nitrate poisoning
may occur in livestock. Sampling forage or hay for
nitrate levels is recommended.
Page: 4

L
6 �
� ANIMAL WASTE UTILIZATION PLAN
** Acreage figures may exceed total acreage in fields due to
overseeding.
* lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and 2 above:
CROP CODE
CROP
UNITS
PER UNIT
50
BH
HYBRID BERMUDAGRASS-HAY
TONS
SA
SUMMER ANNUALS (I.E. Sorghum -Sudan Hybri
AC
110
SG
SMALL GRAIN OVERSEEDED
AC
50
WA
WINTER ANNUALS (I.E. Small Grains, etc.)
AC
100
TABLE 1
TABLE 2
TOTAL
TOTALS FROM TABLES 1 AND 2
ACRES
LBS AW N USED
28.26
7289.25
0
0
28.26
7289.25
* BALANCE
-527.25
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.
Page: 5

ANIMAL WASTE UTILIZATION PLAN
*** This number must be less than or equal to 0 in order to fully
utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffers, filter strips along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than the
acres shown in'the tables.
See attached map showing the fields to be used for the utilization of
animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient
rich and will require precautionary measures to prevent over application
of nutrients or other elements. Your production facility will produce
approximately 1087.8 pounds of plant available nitrogen per year in the
sludge.
If you remove the sludge every 5 years, you will have approximately 5439
pounds of PAN to utilize. Assuming you apply this PAN to hybrid
bermudagrass hayland at the rate of 300 pounds of nitrogen per acre, you
will need 18.13 acres of land. If you apply the sludge to corn at
the rate of 125 pounds of nitrogen per acre, you will need 43.512 acres
of land. Please be aware that these are only estimates of the PAN and
land needed. Actual requirements could vary by 25k depending on your
sludge waste analysis, soil types, realistic yields, and application
methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the
soil at the time of irrigation such that runoff or ponding occurs. This
rate is limited by initial soil moisture content, soil structure, soil
texture, water droplet size, and organic solids. The application amount
should not exceed the available water holding capacity of the soil at the
time of irrigation nor should the plant available nitrogen applied exceed
the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables 1 and 2. Failure to apply the recommended rates and
Page: 6

� ANIMAL WASTE UTILIZATION PLAN
amounts of nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application
rates and amounts.
Tract
6454
6454
6454
6454
6454
6454
Field
Soil Type
Crop
Application Rate
(in/hr)
Applic. Amount
(inches)
1
SA
2
WaB
BH
0.60
*0.96
3
BOB
BH
0.75
*0.65
-1
WA
-2
SG
-3
SG
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations, the application amount shown cannot
be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180.00 days of temporary storage and the
temporary storage must be removed on the average of once every 6.00
months. In no instance should the volume of the waste be stored in
your structure be within the 25 year 24 hour storm storage or one foot
of freeboard except in the event of the 25 year 24 hour storm.
it is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply the
correct rates to the acres shown in Tables 1 and 2. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may
make this plan invalid.
Call your technical specialist after you receive the waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate prior to applying the waste.
NARRATIVE OF OPERATION
Page: 7

lJ
WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
5. Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
G. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be considered.
Page: 8

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to
wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly into water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
the site.
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. vegetation such as trees, shrubs, and
other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 9

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
18. If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22. Waste shall be tested within 60 days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when these
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be
maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North
Carolina regulations.
Page: 10

ANIMAL WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm:S.E.A. LIVESTOCK
Owner/Manager Agreement
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
North Carolina Division of Water Quality (NCDWQ) before the new
animals are stocked. I (we) also understand that there must be no
discharge of animal waste from this system to surface waters of the
state from a storm event less severe than the 25-year, 24-hour
storm. The approved plan will be filed on -site at the farm office
and at the office of the local Soil and Water Conservation District
and will be available for review by NCDWQ upon request.
Name of Facility Owner: SHERWOOD ALLCOX
(Please print}
Signature: Date:
Name of Manager(If different from owner):
Signature:
Date:
Name of Person Preparing Plan: (Please prtnt)Wilson Spencer
Affiliation:NRCS
Address (Agency):
Signature:
Phone No.
84 County Complex Rd.
Clinton NC 28328
Page: 11

ANIMAL WASTE UTILIZATION PLAN
ANIMAL WASTE UTILIZATION AGREEMENT
(Needed only if additional land has to be leased, etc.)
I, , hereby give
permission to apply animal waste from his Waste Utilization System
on acres of my land for the duration of time shown below.
The field(s) on which waste can be applied are shown on the
attached map.
I understand that this waste contains nitrogen, phosphorous,
potassium, and other trace elements and when properly applied
should not harm my land or crops. I also understand that the use
of waste will reduce my need for commercial fertilizer.
Adjacent Landowner: Date:
Waste Producer: Date:
Technical Representative:
SWCD Representative:
Term of Agreement:
Date:
Date
19_ to
(Minimum of Ten Years on Cost Shared items)
(See Required Specification No. 2.)
Page: 12

ANIMAL WASTE UTILIZATION PLAN
STATE OF NORTH CAROLINA
COUNTY OF
I,
Public of said County, do hereby certify that
a Notary
, personally appeared before me this day and acknowledged the due
execution of the foregoing instrument.
WITNESS my hand and official seal this day of
. 19
My commission expires
(SEAL)
Notary Public.
Page: 13

ANIMAL WASTE UTILIZATION PLAN
Waste Utilization - Third Party Receiver Agreement
I, hereby agree to apply waste
generated by in a manner that meets the
Waste Utilization Standard (633), or use an alternative waste
utilization system that has been accepted in writing by the
Division of Water Quality.
Third Party Receiver:
Date:
Term of Agreement: to
(Minimum Ten Years on Cost -Shared Items)
STATE OF NORTH CAROLINA
COUNTY OF
I, , a Notary
Public of said County, do hereby certify that
, personally appeared before me this day and acknowledged the due
execution of the foregoing instrument.
WITNESS my hand and official seal this day of
, 19
My commission expires
(SEAL)
Notary Public.
Page: 14

7i 0�4
*4.3 M�AN
74.
4�
"OF
Vf
AA

USDA--SU I L QEm v, vL- y, .--
i S03--D EAST ROWAN STREET DEPARTMENT OF
PHONE 1919) 5?2-7963 AGRICULTURE
v--------"-------------_-----'.---_.-------------•-------------_.-_.----
OPERATO : W4A/T 'S Ec
SHERIWOOD ALCUX °U007),V�o
Please review the attached p I an and spec i f i cat i ons caref loy . SFCnON
Retain this plan for your use and records, It is vitro ¢ i Al
recommended that you, your contractor and the So i I Cons�Cj i onJ 9�
Service personnel are 'sn agreement as to how the waste Ia
is to be constructed. SCS personnel will meet with aINm71 �
concerned parties and walk over the site to explain all flags
and markings. It is important that everyone understands what is
expected so that final construction meets plans and
specifications and the job can be certified for payment ( i f ACP
cost —share is involved).
The pad dimensions and grades are the best estimate. The
builder or contractor is responsible for final layout and
design of the pads. SCS personnel will assist in a limited
capacity-, as its major concern is the proper design and
construction of the waste treatment lagoon.
The actual amount of material required for pads and dam may
vary from the estimates, The design will attempt to balance
cuts and fills as close as possible. If additional material is
required after construction is complete on the lagoon, the
contractor and owner will negotiate on the price and location
of the borrow area.
It should be noted that certification of the lagoon will depend
upon all specifications being met. Import s include
length, width, depth, slopes, topsoil placement, correct
elevations (top, bottom, discharge pipes), and seeding.
ARE CULTURAL RESOURCES EVIDENT? YES NO
DESIGN REQUIREMENT: 561,269 cu.ft=21,528 cu.yds.
ESTIMATE OF EXCAVATION: 4749174 cu.ft=17,562 cu.yds.
ESTIMATE OF PAD: 260,091 cu.ft =9,633 cu.yds.
ESTIMATE OF DIKE: 79,920 cu.ft =2,960 cu.yds.
ESTIMATE OF MATERIAL FOR SANDY -CLAY LINER: - 0 cu.yds
ESTIMATE OF TOPSOIL REQUIRED: - 340 cu.yds.
Ratio 1.4 : 1
--- Total Excavation=17,562 cu.yds.
Job Class IV
Designed By MERMAN RIGGS 11/25/92
Date
Design Approval _� ---- — ///Z,�/9y
.� Date

-•fir � '�" �., i-, o`..
�� p � .. ''k�yc'"_'1 _ .1:7• :�'�''_ A:.,.'. �a.4f �0 � 8..4 � r z •�•!'► s >a ter,. �, :- , ,,
,IR�+b- , :,,;_r,'+r ::- . ' ` `.:.•. .a.-:." , t�,,.•i•. _�fi Jl Ad''-a.:,.�w�'.."5 N f Y
�"� vl. �,•er {�l �-' w'. I�i•.t• 'l '4�. �rlr••1�9"" 7I f
�, 1t.. .r•?_9 .1! ��:�'! a Fti �•'�- •.tta
14
N1• C`f. - i r �;i.1y. A �y, rugyC:1.Ln."•r,;•J 7 to t •=yju'kar,."3T.=r.r- :.;'=:w.F:r�+ r023
. r�^ C+i�C•, �' �ry - i ;
I / :r T ,.
(.I ,',(;,. `;� fit• +� r .t r c.r. - r '1� F' K •.i a� 1
' ,, III r. r1•. M x' n i il�r�� ,rw•. t �tw 1 4 I r �1�: Via';?':5!�/�� j
i.r �;' i J ( ; �" , ``s• h'ii"', rq i4{•:y��I ,%r' } i'�rj�77,�i.::,: ..'.
�` . r t i' fi �P • ; w: tY .4:. V�rr'i''S• r� I a.�s„� '� ti'7 t r�{ i f,. ..
j�'�•'Y ;�.�. .�Y`�F ��, !!�it,:(S - •:'�•rQ'. L. �r"� ltT.�.�s'.!�':I!_:..h. l.- `•w,.
fV
arhri '[ r ;�'ht `S.' 71 : '�• I �+ I.r'` 4 �.{. r •T .. n. 4
�� 'I. "r�•� .ri� i. r••�r , r�... �' � � ;�, d. �{I1 � I S -�� 'fl 'ii' ',�
ykl'
.l,r*f eT.Z s w7:r ,..�,�.. P y ,I • ` ,� -•r• J+ `
' � :� ` 3�/•+'.ri1 x A r n.;r -. r�` � ak i f � . ij .i + ti � I -r.
3•} f • f' •l x ;: x ♦ J " 1} �� I i ._�
01.
�'I � ,� >�' '!''ckj4'L'+�i � �- ,��id Y �� +'�r�...,'�':41+ �{i' i r yy,�,"• ���'f +f dY i• yi" �
1 �I•F i y -,,r.. r .- �,. .,�.. T.. ar.��.9n; � 7.1 t ;,• wz
�,_ /ti, x t '� r't ��, .•�. yj. '-
�ri� .,tr j..r-..Fei. ,^•' y\ .,.4rjY :y. �i.r I'?'� / i .nt i'•P(f� ��'"; '' :v,•1',r '.r�`„i .�- •S
��;., �'+"' «x; F, ,./,.�: r4 ��Cn y� `�•','r ♦ v�F-nr,1�. "i q•', 'Jr "�.ti.r-'4' � ' .
fl ��*.C7 G'.. #, p,�•`:�yr .:d�'3 ♦t / �b� f 1 I.w � r} a�rL� �y.f''C ��
f yt7�'�•'^`l"•'�rJ?��..,. �t�J�r� y �� 7!,':� { �T�. �!i �:��r - �� rd.' '�
-.- �.c4 -"•�: erh* � + .•.'^Z.y '�ii! {. 1 �' 1+=`-• /�� - 2,� _ _f c � : slc. �+ i�'t. _ .4,"R, ' °
•�� �yi `�YnZil���rrF �, t' ,A w �� r •:r �Y;•—•5�.����ytir..t.�r _ :.•.i '.
Y�.is I".j-�r' + �..t ���'`Ri�w �r i' •• ' y. -} � �'Il .;[�x•
� ••.,Y � ,r � / G"r "'�. IaY f. +L �'i, k i r+ 1, yit '
,.`1i.� k�,�.15'� _•+tr� a y��Fvt�,��.,,.-r�y�i�"I I`51. ;y'i, �® •c. .+i-:�'„i.r
'�1}1�.7,,'v,s't t."lr''��}Y."r l•�ri`' I y'�i t• ,! - t-•;-T' —a r �,Iz tvt 'Tr
r'S.l` �i:�ii."IC�i:u�iiUtn¢L`.Ll bliw' ,•rm�� ��I:�Ja.rie: i al.l� a� il�ra'!'.�1�� ram. S.
`'•5 : �-�:3��7.T''�i,is ._.. •:. �.1i�'i�1:i�i�:7x4r ._. .,i,17r_T"�i':�{

NNE
■■■
®®■®■®OMMEMME®®®®®E©■m■■
m■mmmEm■m®mm®mm®mmm ■■■■■
r4mm.�mVW.:® ME ®'m ©'m olmim m BONNE 0 ■ ■W
mmmmmmNoMinnow Elmo ME■I■■'■MEN
r-��m�®®®®©mom®©®®®®®�■ ■�■r�®

1
SAMPSON COUNTY
NORTH CAROLI NA
•
PREPARED BY THE
NORTH CAROLINA DEPARTMENT OF TRANSPORTATION
DIVISION OF HIGHWAYS —PLANNING -AND RESEARCH BRANCH
IN COOPEUTiONWITH THE, .
�--�'
U.S. DEPARTMENT OF TRANSPORTATION
FEDERAL HIGHWAY ADMINISTRATION
SCALE
ietC
M1�
I 0 1 7 7 a hUM
0 1 A4Ri
ly
W
"
SCALE FOR ENLARGEMENTS
4 IRK
waypau a)wz11.E
1 llli.�_!'
.
i
'e
'. ••
lot
•'
i
tr
�i
�.a
♦
al
4 •�15+1
1e
u i'
I,4
•e
1947 ♦\
i
!!!.l
R4 Fi01.O
L1lE 1 � 7. r tT7e � �{C,.
•'j' tali i lt� .� ` •
.a'..tC. • ray
ry � t A \ r..
• i
F
M Taylan Bow" rA fN a7 ?LZ � 4 a � 7t rA /.f
!.l74 n
•
} i ISJ
UK
for r.+ L t 1129
, 1711 a his
t�
uAz
1r IOR 75f
S
9
'» tle! 111e, t t sfLLU
�!! �♦C •.
!a
1141 v
r 1➢R1
4
.•y4%' q'
.
LM e• y
1111 tF
>>
1.LSe 7
-+n UAL
h
111.e }
+ Lin
tam
1131
::�
.G-1148
{
a Ell
1.4P1 i \
.ti
J 1' ? illi
�
1I
b lily 7.0 tit .
v 7
7 LUA
f
L1Q Llil 1134
flf .J
!fft
V
.y
Ckrt
i1r
114i
P Y
11a try J
11ii M
JJ j �. Ig:.
11 1117
BLACK 411
1.9
.11lk U
7.1
ll31
arl
!fit Jim7r iln ,� [Mr
�
J171
•
Onk
t i iilu TumMa.Y
till
�R ••►� 11I1 ti
11i
III
P0► 11! �
p
EfEI
Iffi.41
.�,/r

N. C. C-41
TOMAHAWK,
Jy pRANf,GF. �l
Nf_ 4 WFIfT£ LAKE 15' QUA
Cam / 34078•F3.TF-024 o l Y 1J
` I' ))
1986
` 137 ll�
7 DMA 5353 111 NE -SERIES VB42
.,Caml.
IN
jo
O
- -- - - 0 0
133 �1� �>J '�/ C�•
'a
em
;`..J ' - � � �,//i� o`er •�, U`�--�1.
313E L. /

i
• U. S. Department of Agriculture NC-ENG-34
• Soil Conservation Service September 1980
File Code: 210
• HAZARD CLASSIFICATION DATA SHEET FOR DAMS
LandownerSHERWOOD ALCOX County SAMPSON
Community or Group No. Conservation Plan No.
Estimated Depth of Water to Top of Dam Ft. Length of Flood Pool Ft.
Date of Field Hazard Investigation 11/24 92
Evaluation by reach of flood.plain downstream to the point of estimated minor effect
from sudden dam failure.
st, Elev. Mt. evation
Kind of :Improvements: of Breach
Reach: Length: Width: Slope: Land Use Improvements : Above :Floodwater Above
: Flood Plain: Flood Plain
Ft. Ft. t. Ft.
2 .
3
Describe potential for loss of life and damage to existing or probable future downstream
improvements from a sudden breach A SUDDEN FAILURE OF STRUCTURE WILL NOT
ENDANGER LIFE OR DAMAGE PUBLIC TRANSPORTATION, LAGOON IS LOCATED IN A RURAL AREA.
APPRO. i'i3000t TO STATE ROAD. APPROX 3001 FROM A TRIB. TO BLACK RIVER.
Hazard Classification of Dam (a, b, c) (see NEB! -Part 520.21) a....
Dam Classification (I, II, III, IV, V)
HERMAN RIGGS, SOIL CONS, TECH.
Y
Warne) (title
Concurred ByZ.! .c
name (title)
NOTE: 1. Instructions on reverse side.
2. Attach additional sheets as needed.
Date 11/24/92
Da to �! 2 Sr q

l3perator: SHERWOOD ALCOX County:
SAMPSON
Date:
11,•'25/92
Distance to nearest; residence (other
than owner):
1320 feet
1. STEADY STATE LIVE WEIGHT
0 Sows (farrow to finish)
X
1417
lbs. —
0
0 Sows (farrow to feeder)
X
522
lbs. =
0
2940 Head (finishing only)
X
185
lbs. —
296900
0 Sows (harrow to wean)
X
433
lbs.
= 0
0 Head (wean to feeder)
X
SO
lbs. —
0
TOTAL STEADY STATE LIVE WEIGHT ?SSLW) — 396900
2. MINIMUM REQUIRED TPEATMENT VOLUME OF LAGOON
Volume = S96900 lbs. SSLW X Treatment Volume CF/lb. SSLW
Treatment Volume CF/lb. SSLW= 1.0 CF/lb. SSLW
Volume = MGM cubic feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0 cubic feet
4. TOTAL DESIGN VOLUME
Inside top: length 325 feet width 230 feet
Top of dike at elevation 56.00 feet
Freeboard 1.3 feet wide slopes 3.0:1(inside)
Total design lagoon liquid level at elevation 54.70 feet
Bottom of lagoon at elevation 44.00 feet
Seasonal high water table elevation 46.00 feet
Total design volume using prismoidal formula:
SS/END1 SS/END2 SS/SIDE] SS/END2 LENGTH WIDTH DEPTH
3.0 3.0 3.0 3.0 317.2 222.2 10.70
AREA OF TOP
LENGTH X WIDTH
317 222
AREA OF BOTTOM
LENGTH X WIDTH =
253 158
AREA OF MIDSECTION
LENGTH X WIDTH X 4
70462 (Area of Top)
39974 (Area of Bottom)
285 190 216790 (Area of Midsection X 4)
CU. FT. = EArea top+(4XArea Midsection)+Area Bottom] X Depth/6
70482 216790 39974 2
VOL. OF LAGOON AT TOTAL DESIGN LIQUID LEVEL = 583588 CU. FT.

5. TEMPORARY STORAGE REQUIRED
Drainage Area:
Lagoon (top of dike)
Length X Width =
325 230 74750 Square Feet
Building (root and lot water)
Length X Width =
0 0 0 Square Feet
TOTAL DA 74750 Square Feet
===> Design temporary storage to be 180 days.
A. Vo I Lime of waste produced
Approximate daily production of manure in CF/1-13 SSLW 0.00136
Volume = 396900 Lbs. SSLW X CF of waste/lb/day X 180
Volume = 97161 Cubic feet
B. Volume of wash water
This is the amount of fresh water used for washing floors or
volume of fresh water used for a flush system. Flush systems
that recirculate the lagoon water are accounted for in 5A.
Volume = 0 Gallons/day X 180 days storage/7.46
gallons per CF
Volume = 0 Cubic feet
C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by
largest amount.
180 days excess rainfall = 7.0 Inches
Volume = 7.0 Inches X DA / 12 inches per foot
Volume = 43604.167 Cubic feet
D. Volume of 25 year — 24 hour storm
Volume = 7.0 inches / 12 inches per foot X DA
Volume = 43604 Cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 97161 Cubic feet
5B. 0 Cubic feet
5C. 43604 Cubic feet
5D. 43604 Cubic feet
TOTAL 164369 Cubic feet

6
r,
&. SUMMARY
Total required volume = 581269 Cubic feet
Total design vo I LIMB Ova i I .= 585588 Cub i c feet
Miry. regrd. trtmnt. vol. plus sludge accum.= 396900 Cu. Ft.
At elev. 52.00 Ft; Vol= 404848 Cubic feet (end pumping)
Total design volume less 25yr-24hr storm = 539984 Cu. Ft.
At elev. 54.00 Ft; Vol= 555040 Cubic feet (start pumping)
Seasonal high water table elevation is 46.00 Feet, which must
be lower than the elevation of top of treatment volume 52.00
i
DESIGNE BY: APPROVED BY:
DATE: 1 1T_.'ZS `�jZ DATE:
NOTE: SEE ATTACHED WASTE UTIL12ATION PLAN
ADDITIONAL NOTES: