820035_CORRESPONDENCE_20171231

NUH I H UAHULINA
Department of Environmental Qual

PLAN OF ACTION (POA) FOR LAGOON SLUDGE RE
ucRoN EIVED
FEB 0 12006
Facility Number: 82-35 County: sffTffMLLEREGIONAL OffICE
Facility Name: Rudcar Farms, Inc.
Certified Operator Name: James Carr 060pNpperator
Note: A certified Sludge Management Plan may be submitted in lieu of this PDX
Lagoon 1
Lagoon 2
Lagoon 3
Lagoon 4
Lagoon 5
Lagoon 6
1
a. Lagoon Name/ Identifier
4.3
b. Total Sludge Depth (ft)
c. Sludge Depth to be
0.2
Removed for Compliance
(ft)
d. Sludge Volume to be
Removed (gallons)
e. Sludge PAN
(lbs/1000 gal)
f. Liquid PAN
(Ibs/1000 gal)
g. PAN of Sludge (Ibs)
(d x e)/1000
Compliance Timeframes:
If the sludge level is equal to or higher than the stop pump level of the lagoon or if the sludge level
results in an elevated waste analysis, a sludge management plan that meets the requirements of SB
Interagency Group Guidance Document 1.26 must be prepared by a technical specialist and submitted to
DWQ within 180 days. Work to reduce the sludge level must begin within another 180 days.
Compliance with NRCS Standard 359 must be achieved by the expiration date of the current permit, July
1, 2007.
If the sludge level is non -compliant, but below the stop pump level of the lagoon, compliance with NRCS
Standard 359 must be achieved by the expiration date of the current permit, July 1, 2007. If future
sludge surveys do not show improvement in sludge levels, DWQ may require the owner to develop a
sludge management plan that meets the requirements of SB Interagency Group Guidance Document
1,26,
SPOA 5-18-04 Page 1 of 3

NARRATIVE: Use this section to describe the method(s) that will be used to lower the sludge
depth. If microbe use is planned, specify the product to be used.
Quellz Products, Inc.
A product called Quellz from Quellz Products, Inc. will be used to reduce the sludge in my lagoon. This
product is an enzymatic solution that stimulates the natural bacteria in the lagoon being treated. The initial
treatment is based on 'the estimated volume of the lagoon at the time of treatment at a rate of 1:50,000, and
maintenance treatment is added based on the amount of waste generated on a per month basis at the same
rate.
I hereby certify that I have reviewed the Information listed above and included within the attached
Plan of Action, and to the best of my knowledge and ability, the information is accurate and
correct.
James Carr
Facility Owner/Manager (print)
t
ability Owner/Manager (signature)
Phone:
Date: . /-30-0
Return this form to:
Fayetteville Regional Office
Systel Building
225 Green St., Suite 714
Fayetteville, N.C. 28301
SPOA 5-18-04 Page 2 of 3

o�0� IN 4rF9Q�
Q 115� -r
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P. E., Director
Division of Water Quality
October 1, 2004
OCT 15 2094
Rudcar Farms Inc _.
Rudcar Farms Inc
PO Box 857 DEtdB-fAYET'fErliLLEREGIONAL OFRCE
Clinton NC 28328
Subject: Certificate of Coverage No. AWS820035
Rudcar Farms Inc
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
Dear Rudcar Farms Inc:
On June 11, 2004, the North Carolina Division of Water Quality (Division) issued a revised State General
Permit for swine facilities. The General Permit was issued in accordance with the directive of Senate Bill
733 (Session Law 2003-28).
In accordance with your application received on February 3, 2003 and in accordance with the directive of
Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to Rudcar
Farms Inc, authorizing the operation of the subject animal waste collection, treatment, storage and land
application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AWS820035 which expires October 1, 2004.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Rudcar Farms Inc, located in Sampson County, with an animal capacity of no
greater than an annual average of 6080 Wean to Feeder swine and the application to land as specified in
the facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or
Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary,
they may be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a
rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Since this is a revised State
General Permit, it contains new requirements in addition to most of the conditions contained in the
previous State General Permit. Enclosed for your convenience is a package containing the new and
revised forms used for record keeping and reporting. Please pay careful attention to the record keeping
and monitoring conditions in this permit.
Aquger Protection Section — Animal Feeding Operations Unit
1636 Mail Service Center, Raleigh, North Carolina 27699-1638
Phone: [phone] FAX: [phone] Internet: h2o.enr.state.nc.us
An Equal Opportunity/Affirmative Action Employer — 50% Recycled110% Post Consumer Paper
NorthCarolina
Naturally

If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 21i.0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100 foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Duane Leith at [phone].
Sincerely,
v
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all ec's)
Fayetteville Regional Office, Aquifer Protection Section
Sampson County Health Department
Sampson County Soil and Water Conservation District
Permit File AWS820035
APS Central Files

.. - ,4.''LI.T �.,�. .'...V.:"..,:-.!V4i.%..,I,..>....,"I. - ,,' i, , �iW--. - .-.c C., Iw1 it, ,
'".I% ' -',.,. ,.,�. ,..",- 'I-,-- .'y.�k' ..'- 1:-, � :�-,.1 . .-. P,� :- I-.e ,bI. '.�--I -'�-� , I, �'-,,r..!�.-. -.- ,. .I.I ...:, ,-
'.4. .:, . "
,r I .-, 4�
/1
i
-* ,-
/ . /10P
.
--,4.k�
,. "W
-
.,ht
,,, ', --.y
..f'4Ij'- .- r,
!"t,- ,
1• .I,. , l,. ,w-L.",
?,%.
,
.
'C', ,i- - .., .., ,
.. :, - 'e, � . , - . . , , - , , - '! '. .. , " � . .. .. - " '� . . '. -'. - . , .
. .- I , - " , . . " . ;!... -'! - -. . . l.; h
, ... ',-.,, T; , , , " "' " , , , ': : -")"Ol '. V 'N -�i " I 'I; I , , . . I � . I . I : .. .. !,
, I . . .. . , ,' - - -, - , ;' �:, ,; - , -, , , " I � , .,.,.I I % , . .. .. 1. � . 1. .. ..
'! .$ '­ '�- . r, . , � ., :, ,--": � ;. , . . '- . , I . . -, :
. ..... era'
."-. . , , . . . . , : , ;.- . I I
."; ,�L e. Z .. - .; : . I .. - - - - � -. .:, , , - , .: ",*. ': - ,,� ,-, ..., 1� + . , , ., .., .1. ',-, � . . . I , ,
.16 : " . , ... . . . . .. " , , . - : . , . - � , . , . . , .•� . . . , . . - ; - - . ,
, , . . ., , e"A . '.' - - .. I.` -:� k> .
',I`.'. �.C.l . , , . .� I •. , -. . '� -- - .. , - -� -, , . �,J' + , � 'I.- , . I - , . . I I - .. j, .: - , .. . . . . . . , I , . �-, . :... ,
. . , - - '�:" ".. ...' "Y' ,,, . . ; . I - . %. ". -*�-
- I � , " .., ,,-J� -.,;,� ", . . . .. , � , , 1. ,
... .. , �, Z.,�, - , . , , Ir " -, . " .. - ,-.,. -, " , " I ,-"-A-. , ., , , - , �. Y. . -
. - - - -
- ,.:, '.'. ., ,., ;*"-",""- '. .
.- - ' I ; r-, 7'. , . , - - " '. " , 1, "I - .
' , I - .. ," , -7. - " . I -,�, - .,:;., .", - .: - - ,-, - , , " :'�
. . . . " ,�: -,�,, ` '. "•1, " -� . .. .4 -. f, " , , " , '.7 , - ,,. - . -.� . . . , , . , , 1, - .11 ,.'.:, ,* .. , , ,-,� . � . , I '. �- ,
: .. ,•
? I
.j ­- " � I .'� �;�: "I .:, r '. ' . ".., .. . - . -, � �.,-. .'-. 1. , -;,� .". . - - . . r - �' , , .. .. .� ..
, . . . . - � .. , . � -�! . - '. . . - . . . . I .1 . . .
'
� -, , , . . , �
.�,';.- . � .
-, ", ,- - ,I,,,- ......
+ , , �,
- . I I
- , � . . . . + I -': ' I .,,,�
`; !' " -�,�� ,+" -'�r- - 11 - I - ; ; 1.; '. �---,, -* -.- ." , , , . , . "'�-,. " . . _ " , . I
� ,; ., - .. ,:. �,. �, - , . . , , ... i .1 I ;-. - I � , 7 � -.,•"I I � -p , �- �
, _" ,�:. - - I.1, . I .., . � , , , � '. . . I .� � . , , , . . , . . . - * - .1 .
•
% .. . *. -,,'-- , ." I p ,
. .
'l-
.... , --- . 1 . I -1 . " .,...
)I , -,,'- - - . .. :'� . . � .. - - � , " , - . � . .
k, '.., 'I, .., _ . . ': -, " , .
. . .. .T + i- . , . , " - '.. , ,;. , -, . i, . ti, � .. , � . . .. . . . '. I-% " '.
. . , . . - ,.:" ; - - . , '� " :, ,�.�- . 1. . , , .. ... 11 •.;, "I ` ., '. , . , . , ,i' I . . , . � -, -.'6 , .
.1,% ,,�. ,,, " '!.',-- - .-' " "".
" .�. .
%; , - . � .. -, , - .,; , : , . " --
I -� � . . , . ., . . j ""': , !-�-� �` 1� . " ." .� I , " , -
' " 1, � 7r - . . ".. .. 6- . , . I . -, . I ".; .. , , .-.:i ..,. ,,,, - ': -� ... k .. � � I, " .,k' ,,� - . I
� . � .. ; * - - -1� I 11 . " I
" " - - 11 - . I �11 I
,-,-, I :-��,-�, t" - . � �"i, ; -, I v '. . .f� .
.. , . .
�-� "'j,
•
•-- , 'S
, . �--,- .:,.
. , .
1, ;11,
'I , .., , : .� I ,c . , , , . , -1 1.
�,.', . �; . , -,� r ,IP , , 0•
;. � " , , . I . 1, . . I I I -
- "' ., . " I .�.. .. . I , 1>4 . . I .-,-, "I " , ... , r , I . I � W -1, I .." - . .., , ., " , . . , I ....�- -
. , , . � I . I I �11 . " , ",1, ;A. - , . . ­
' : - - I " , " I", .�.., " . % . " ,�, V�, �.. � � . . . . � IL L - - rr . ,
. . . 11 . ., ., � Yl 1.
'� . ..I . . - , . , i , ;., , - . , ;( - , , -'- : : -, ,� � ,-:,,- - , " - - , , 14 -
J - - lo. I. , - ,,, � - . . . .:! . , - , . � 4. - 1. . . . .. � I � 511 . , , ,� .. . - ",ill' .... ... I I. , . , . . , .. ": . , : I � . .1 .. - ;`)� .. -? , ...I, ,,, , I , . , . , ,
. .4v- 'J� ...... ! r, -t , - . , : , �.- .
. , - !')�!,--%-11. I '� 'l- I I - , ,
t$, . . . � I 1. �45
, , ,,, .
- . . , :f"" 1, ,
; ..',,�`�-, I . . . . ... : r
" � fV - �_r. ' - � . .•
, - , ,; ? . � I ;: : : , . - , � . I " -w 4�, - - " !'T ,- -, . � , - - �% . -. , r . f% , . , - ...... - .
",-. ,� .•
, ... , , . I . .i : . � � ,�., . " 1 , ., . I � 1. .. � . !. . 1. �' ),A. , ,� '. I . � . i,�; I , ,� '.' , " ' , % " �'r - . , I - . � .. '. " , , , . � . , %� . �. I . . .... - " .- � -, ; . r . - I .. . . . . ...
. . I - ". ,.:� � . , �.-,- ,�,-.,', I.,_ , "." . I - . ! f , , . "
.. .. ." , , $ , :,. I A- - . '-. .
-t , - . -�: - '. , '.'� . � .11 .� '- i ,;, - , , " " . - .
1, . . �., -, .. - . . . I I - . ! , .� 11 1. �
, , .'.�•,� . ', . r '". ;. ' � , 1: '� - � : , � , " �,,,, I . - !�. , , I -'l 1. � j" . I , - . ,A I : . �l
-�� : , , '��', V I.",'; � ;,' . . , '..,�. :., . 4 . � . . , . , . . . , .. ` '- , � 1. , ��,., S lll'--,."� � .., "-�,. �% , r I L �',;;'; i, ! y � I I;, e- " .,rL; ','� � ' ' , " - " �'� 1 , j ,'�,
, , . � , , ,,,, , , '. ,.� . : , . , " -',,: -, - , 1 z - q- -Il, , "I . ��
I.r.,, '.'.,-', � , � � , � : -, ,-. , �� -,� .. I . , ": � �l , I , . I . . I
, - - ,; : , - -'-, *, ": I , .. ,� . ".." .� I ��-':%. ...p . 1 A�. -�- -, - - -*-.-�!".," I
-' -, - - I. , - , , ; . - -, %: � i � I W. . . -� 1:�.,` , . -I -, I , *. " --", .
` ,.,' .'" ". '-,�L: ', , , i•
'.. •.,- � , , � .1. " '. - :�,-' i " "' "" - ��-, . •- �
•
0 � , .V --- - --- - - - -- -- t,�; . 1. 1, . ,-.,! .: ,,- - �!�` I , 1�1' *;,O) � U I " , , � , , : ,,,. �,, , .. �,�;, �!/' - I . - , : �;, -; .
),-, A. *.- , t., . i", '. .�." ., ) �, I '�,.;* -, ,- I '-, •, '%� , - ", , -;�. .. . . ,.,q..,, 11 1 `.470-��,.-, , , � " - ", .., , 1'7� 7 % -,� ... - I , , X t, .1)%'i*- , , . I . . . - .7-,�., -, � 11 .
) - - I - ", - - I 11 " I - - 1� I -;; : -�-! '� -,� , - , . -'. :1 � '. . ;:,
.;-.*. •-, ,.:. - . . . . ..".. . . . - N:� . . , -, , ok . ... . -, , i . � v,
- ,,, , ': - . .. . I V - - -J- p , . I I..."k,111.1 .1 , 1.
,
, .1 . t - " , "; '. ,4 . . . r;� L"--'�-:" I , �% - . * --W I i 41 I . -! I - - - " . . , . . , " . I . " -5 " , . ld.,,,* - '- I , .'., ,-, t - :: :I' - I
- 1. - - - . .. I . . .. . - , . . . .. . ,
.: , , .,_: " ,,,,, , , , , !'-. " � - --.,." " i. �l , , , " "" "
" , - " �- -,-- � , ,6 � � .; I'-,:- .. . �, . ....
1 - .,:,r" ; , . . U
. . .. i . �.10,
I- ,- - - - ... i; - -, ,.,, I' I -,- , . , .. ,C ." , � . . . . . "'� � 1� . � ,� , , - "' - - . . , " I - .. " .",*. , - c Z, . , .. � , ,I
- , 'r "a ­ lkl--� . .. , . , , , " :. . , I . . I I - ., , . � 1, - � , ,� .1 .
- - - , - - - - ..,- - - ; ". 'Z, ,r . ; �
,P� I , ­ r . r, , . . �. . . - .." , - , : I , ., ; � I .. I' ""p- . o � - I ..".:;�. .. ...., :, , ,
t - N . . . . . . . . ; ., , ", .2 1, . " . -, . - , ,�r, , I " . 7:; 1 " I . .. � . . - - I
"r
. �il. I �, I , -, rr . .. 11 , , . . I I .. " I - - I �
wo � .
"' k '. - , .1. , I
... I 1. ;. . '. - � . - I- ,:",:!. . .
. ., . ! " f i .., : .: ,- ! '.. , 'r ,. ';7' . " , 'I.' , .
1,�'llelo," -, - , �-? F,�.!.,,', ,% , ,,, � I.. -.��p -, :. , , .. , � *,: i, " - , ", I - . 1�� --
,;.I I . 40A . . , , �. ,
. . , �, -1 , �, - , .; .. . � - . I . I ; .I .", , I --4, -, ,.. ,- :. - � . 11
, . , , - . I . . - 1, , 2jr , . - , ..:- %, -, -,�-; -,
: X 1. -. L . � V� I I . , - - m I - , :t- , , - I t . . . I . , ,l . . - . . � �- I . , . . .11
'. I . � , . . - - I - . 1. -, � t,� I , I r .. ..), I, .. - . , , , � - , - -
,-'J- 14 , , , I . "e , ­ , 1� I
. . . . . , . . .
,
. .�
"A --�� t ,!'.. I 1, I ; ... I . . . � . >' ...
;� . - - : : ., �, - ; , , , - . 14, - . I � . I . , � . . %,. I
� � - " f .,� ... , ';, .') L-�- f , " - A ty ". I . . .•
. - ". -1 '.... . . .-!, - - % '. " , I r. , ( , .. � 0
1, ,i,� � lill�� , I•-•- - Z�, � ..
, . .. . 1- . 'f� "'. --- , ­-- - , , - , - . - . . . . .. �
- . - - , 4 - . - - .. , . I - :� ,�, -�-, % .., . . -� � . - � I , , . , . , , C . -1 ; :,-,-t.,!!tqN ., . -�',7,- +', - � . . 1$ -, .1 . . , � - ; % - .�� V 71 - -,; 711-3, ,q , , ,
. . .Wl I „%' "I - ,-� 111'r I - . , ,
- �! I �.� ou ;4 '..'..." 1: ", : -. f. ;V` � . -I g T", I . - - I . .�t. ,-,- - - -- -, -�*, - - �,
� I � . . . - . � � . , � "'.1'r- 1- I , ; ." r '. "
-�, I ,1-f - , . ! �'. , � , I
. - -� - ' --.I', 7 - I - I . t ... ..... � ­f. .. ; %, , 1, - -, ,,,, - , .,. "'.", , - , . . .
, - I 11 - I I � !�'.' - -- , I - I.. , - 'I " , L '. r ,
. , �,Al �,-, - . . . .. - -,., . •
1-- I I I , , �L I I �L� �11.11 �l ,'
- �
•, -, I
��-,� , -� � I `,� - -" ." ., . .•.1 � 11 , - . �r � �1. , - 'A .- � ., I .,.,.,;, I .%;r ,:, I 1� I " t'r ." ,
, �,�. * .. , , - - :1 &, , ,� ! ,. � -- . -4 "r. , I , , �, %`X � jl�- .'," ': -' ` '%'� I- ' �,' I"' ,'L ;' 1, , , -, . ', 'L !.' 1� , �� . , . . I
1 !;�. - , , , ..
, :. -.; --,-� *,,, - I , .. 1 � , - -� ., ., - .'. , .. . 1,--�,!,l i -""�', � ' �,� ,�
! ,-,4; : I , - �� - 17� 1 ,.-: �, . . . , i ; I " �4,-. ;! 'r, � A '. "'. . : ll�l I.;,, I ;. I . - - - , , , " , - .-/ . I 4,
. , . , ? , . i . - ; :. , .
�.�,. 4, �j J � , I 11
- , , I ,& , , �
-, � s - i . ". � -, -,. 1 , " - "-'- , 4�0 � . - I. r ';�-� �.%'� . "" . f .
I .; - :, " , � ;.,,,,S V I � .1 �, " .,. . I � ". 1 ,", :� . . 1, - : - �-`lll 11 , I I
: . . � . . .. � ,- �OVA -, , , ?'" _�
- � . 41 - ,.-�-:. '. , .� ,- ,,, I , 4 .. " ). - , I - . , , . 1. ,. 4%, �� 'i",�!i" . , � , - , - - - ,,, ,
, . . , . r, �;,.k.i .1 . - . .... .... ; . ,�,, � " . , .
- ;. . I , - .,: 44 . . T. .�-, , , - . ". I , .� , . �
. -
I ��' , , . . , I , .
.
" I? � I . "I - -. ., .1 , .. " ., . , . - - * , � � F, ; -- - " , - , I ,.,.%,: I - ,,, � J .. ,; � ,:"..'" ", 1 'I I- , I , i . " . . , , , .
" . . . . . - . � " � .. . ; I - . I
. .� . ) . , I . .. .L - :el' . v ".:,11. , I . ..
i k, * I : .
11 I . . I ;:;, � ",:,"', ." "' . k: . ,,, ;, . .
0 f u4• 1, 1, pi I ,.,. ; , ,- " ,- ,.. , - � - . - , - $ . ,
� 0� .4 1 !,. - ? " " � ; . . '. - - 1. ::" k ,,, , , ',-, - , . , ,
-b : J". -;'r
" .,.,I '. �,
, , ..
. , &I 4 , i I, . -, -. ,*, ; , i .-,� ., . . .. . I 0 . " ... . " "... . I.J! .. I . ... " ' ' , "", 'r I . " .... �.;;Ll !. , � - " , , , I -
* - ,� f - . I , r,- �',- .�% � . .., i ., , ; ,,-'�; . i ,l , I , , tj
. , . , , . , , , I I , - - " - I ,I .. ,
,�.., , . �'. � . , I I .. � .,� .. �--' ,a, ", .. I " . . . � . , � , .. ... "': -� I
, I , . . .11 . �.� : :. . .r., .,., , - -.1 , L . .. . .
., � ... . . ... ,
I A �. 1. - ;� 7 ZP r.j, �. , � ! - ;� , - , , N. . - � . � .. , . " �, . .
.. I .. -:�X . � :- --,;AAI - - - t% , " v � `� *I�14 � 'a I f , k , : , '.,-,*, - - ": ,
" - - �V .- I � - " , I �. ,-�. '. ; -L, �'-- ' - ' I "I .' �, ." -, - -, I � � � -..-", .. . K., .. ;- -,
t§ " " . �- t - or " , ;,l'v'0", " .'.',- , . ,-. .. - . �l ,,. . � .,� .,.1 1�
J, .;; I *I,e ...... , - I ' 't, ' I � � r. .
4
,�,, '
, .. .11 . 1 13. - --t I 14T•iwi . i - -` - - , " - -� . ,;4� , -.- ,
1� -ik - X �., "­L. -
� ;r . .. �,Y�l �-. . . , ',
-" 'I - !�A ,,, � , ;V: I . , ��, l..', (o , pl.-IL, I ", , .. 1, - . . 1, , .� ­ _ " _ .. , '� ..' . . - ­ , . . .. �, . , t!i'.'.,- " , .. �� I r
. '. ,� , '. , , _ - ! -1 ,I . . - , ... - , ,�.l .,.� , ..
- . , . I I .•
!" - ' "I ' - �., � P �;"
. .., . .. ., - - :, " -, I _ , ��.' 1. f. :--!.. .. .. , , '. 4,� :��.". , ; .
" - I . •� . i-, - , I I ,... ,'.'.',, � � , : '. . �,--L J. , �h- .,,-� 1 �4,1 r',,� -,' , , i . -, -.1 . :e �
, , , , " ", , , , " I , , ,
- !!� 4 ; I .1 . . � , ,
�, ... e, ,:D -)� I - . . . " %.'� � ,'- �� ,'. %,-", T.-i" �� ;��, �,!. , IW '. ". - , , , , . , ; Ll" et : r
. . . - . I - � I .•. -T'l --� ,It . , ".: .,. , , I , , ♦, 'i .
, �, � 1�� I ; � I - .. /%.;�-.., .; .: %
.. ; " ., I i , , '. T . 1. .1 . - � , - . . '�' , - : i�"llvl- ,:;- -: '.. } .." � ,-, - - - - . 1,
- � , . ,." I -U - t�,4 - , .,;. -;-.-,�,-`��.'-.:�. : ,,��', ,.- , ,,, I -�,'�-�'-"�,�:;�l , .. ..". ... , . ,- .0 ,., " '* . , ,,,j - - � � .
, I . , , 1,-� j�.. k;.I,i . L, ,;.-. , . . . , � , . ... - I 'N r ". ;j, . ": , � � - ..:..:: - !'­j ,-� C - �1. " !I
N ..- , : "P - .1, I. 11 I I. I ,-, ...-) %, " : - fl,
- I .. �
�
, i - ; - �-- I.. ,I i "I. �1' , I'll
- I .11 z� 4 . � � . ,� � - - - , - .. � "
, I , �, ? .. -; I .- - .� , '. .. - I , . . . ; , - -0. . .
. . 1. a . . 4 � - 1,115,�t - I , . 1� •
jr.. � . �,r � lj�'-y,� � , , , - . " - , . . I 1;�,� i�',",, � , " I . �
.1 . , . - ", ,� , , . - , � , - -1. I ,,,
'. .
, , 4 64&,�. ll��ll 4;%� " � �� �•
,�� �-, .. 1, .1. -W �, - ,',.� , .*�:, . , , I .. . '. -, ` ,"� � .. ---� ." �'I' , - , �,.-� -"';� .T,4, -
- . r. , '�, , . t •.r . ,, ;t J. .1 ..".":, '. 1.4 I, . - I . , ", . " - - 'k � -�l - - , . :.� � " � ; ,,, .. . ", , I ; ,; ..;;, ?'. . '.. ; .,
, , - , -, .. , . � ,
1� , '. " , 'k i I' •-:. , I , , '.� .C. .,-�,o,�, , ! 11 - I '. , .., --� �- ., .-..- " . - �- .. I . . .,
t V�t - -I V I "", .,:'l.l. r. " ., '. - . -,�,:.: ,�t"- " , - ...,I !".., , ., " .. "'i ." Y." , -
.: � . !. . � - �% .-� ol, �: '. � ,� �., � � �. , , ., : . 1 ri I ,,�; " i--., - -- .---- , ,. , . . - . I .. �- .. ,
. i. - ! . � . � I - � ,- '. - ; , ., � .". , " . ,:t, , . , - " , , , J- , I , . . , - . , -
11: . f ... . . I �K-j , ;I;� � . " � " ), , - , Z� I - � � -.a, ,
. .-. " 4�- �' . . ... . . �: .lr,x �� t ,, .. . 4.--�-. � ,
. , , f. - - �,, .. ..... . ;l I'l I r ,1. 1. .." L. - . , - , !,. -1. ; �., . :,;? . . , , . ,. , , . " .1 I . . I - - .� '.. �, , "
. . ." . -- . : .; , , ',-� Yt. .. .1 I %,�,�� '. ., . , � . . , . "; . .141, -�l , ! rk.� L , , ..'ji ..
,
. . Y i 4 r3qp-- ,�F - , -�.t , -I .. �, 1, ,P�- :� " I."..,/ � I . , I - .V ,.,: ' ­ . .. I - . . � , . . . �-, I , - : ;�. ,I - '" . .
. ., .
1, .", , 1. �j , � %� L . � � ,,�,% �� , ,'!T r�- ; . , - I - I 1.fa � ..
- . - " � .5 - � P��.r .� .,-- - �
I., .. ,, L. .,. , . , ��,::-r,!tl, - . . J-. � - -i " . . . .. , % .,I" � � j,.. �, L, � , ,,. ,:.' ; �. . I . , , . .. , r,, , . ', -
" - - �- I I . . "'. . � . . .••
... .. : . " "A" . - ,
-�Xf - - - , " �, . . . , t .. .... - ,,,
- .. , � . .�', . � ,- ,� - I " - � , -!-'�-..; � . . . " - '.' % 'N � , , ., 1'�'� 4, , -� V,; , , SFr
1. r 1; �, 1� � ', ' � �
, ; � * " .; : . � . - , , � " � � 11 1�1�11-- -�'; - ! "-,r _ . � ': _ •,.r.� . , - .r, . ' ' ' � - - .' - ',- .0. - ��' - �' I . I I � .., .,r; :, ­ ,. r-,;., .:
I " . i , . . .., 1, � . v � , I - ". - . �, . ; .. ,,r ,
. v ,� , "I. �%, .- ­ r - . �, " L'�', - .) , " _,""', ,
. . _ , .:�
. . I 11 . I - �,, , " , - I �l I .r i. ..4
. . . 31L ,-, � - , . ; " � I.. . . , "., I . . � . . :R I - � , . �l, - ,., ;�:,. - - "!-;.� t, -,. : �! '. I �f .... .. �-;'J'i,iN ,',�-� , , �r Th., - , , , m. j-, - � ,- - , , '. -, ",-- �; �- .v . " I '� '- .
. � .- A - '. � � I : . I '. ." '. - ­ . . "..il" - � , ,,%, . � " ,., .� .1 . L, . . '.�, . � . " - -r; � " . '., +:"., , 17'�n , 4 .'. - . ,V , O
. IK I . .1 , ol,,,,-- ,�..---'J'�-,- ... I I A". � .,-,,'.J � 1,.�C; ., I � . 1� � .. .. , �", I . I
. . , .� . - � , " I 'Pl- .; , . , . , I - .1,
%; " I., 1, . 'ekW , , -,
- I.', .. , , -","- ': .r " , ': , �,
- , " 1'. N � � ,�.!, - .�� I, -,,l i., - � . . . , , ! �_- , �. .1.� I, ) , , " , , ""r -0#'-l- - . , " .
-... . . . -�,j!,,-_. ,..* ,,, .- -. - . 'r ,� j'-' ., ; - � 'I, r. � ,- ,' -1 I �,,!, !t . , , . . . 'I ­ - V, , --, .--"�', . - .. , . .
- .. ' - - j ! i -� '. . , �� L �, - C ,
"', , . � .11 1� .... .. - -- " , . r. -
I , - '*� � 1� .:,-. -,v " '.. -S.J, - -,L . ., I .... .. � . � k �"i 4 �, - � .. ".: ... I 'I" - '.�,\ � , A ,
. - •: :, . :j .1 � . . ��.' I
11 , I .. I I . 1. .� .�-1 -: .'.-'. >;-1, - 0, % " -1 . �-�, �, . .. " " , ,. I � - A 0. -.
- I . -4 - . -; �-,� &,%� .�l " , , - ul� . ,^ - � . '-�, ". , �.".,:" "." , . -I , � - , -• . ., 1 .,., .,.,, - - - " 11 , , ; . - '4 . -,, . *. ,.;� - � -, - , , ,,. i - . - , ", ,
. , . -- 'i . 0, . .41 . ,•
L� ...'�­ ,.� . ­ I. ." r '. . .. I . . �
- - - -:-.--�- : ." .:,.j•.,,i!: ­ ,, . .. . . . � . , - :- , . : " ? I
_, t, i . ' '� '. ,;'.'. , ,- ' , 4, 1, ,,,-., L 'I , - - -I' .. - ,.J',l,',�-;-.-,-;. - , '?� -*.11 11 I I , �. � I , V , , -_7 "! i-. +- .-. , -, , , . -*-1 ", - ! .
, .� " , . . I - � � - , - .�, , �- a - e ,
4 ' �' r !l � '�, "t - � -1- - I , - - �.
I , , " . � - - , 1.1 ., .1 , . , '. .'" '1'�', 't j ". . - I � ' ' ;"?r, .N,,"- -,":4' . ` - '!!:"- I �;- - � ' ,.*, ', -.- .',l,.'y'- . I . . . .- -;,:7�., ,-,.'-,L,.7: , .. . � - - -.- ),� •,- I "t , i . - � . , , , , , .. - 1,
I .. . - I J-� . - I �.�rl', - - ". V, ��. , J! 4141"� ;"-. -1 ­ " I �. .., , . .. ,
. . , I , ", �- --- , - . ., . - -1 .� q tl�,, -, - 7 , 1' , I- V " . :. . -, " i: , ;,: , . . , . . I!, .11 : 11 -
. . i � ,- , , ,.; , ,�',% �4 , . ;. ". - , �;. � - " � . - - . , i- I . , 1� � -
. , ,�, ;;,^r- - , P ,;-- - !� - ,-- - -- -- ,- -- - -:-- ".."ll.. '. , . . . I , ; .1".1 ,,.! I �.; ,.,Y, , r" ., , * - --, , , - , ,,, , � 11
, I . ,,� . . , i , I .. . - 1, .,li. - , , ,!' , " � , k " I - -7 , . . .. 'l ". .. j , je... ., -1 I .-.% - � 11" � �,.,;i ... : : ,(;"-4 -,I, - '- , -� ;e. �'. 1. . . - . ,�
;!.�- Wl'e i - , .., I � ;:- , s " ll.F - . �, ,I- � ,'�,.";: -�- �'. ., ; I . . � � I . . , . '.. .".--"�',', '4 - " -- - , I 1.1,11'�."..�"',.',...A..C,"I'�'rr'- � ' . I r, -, . �'. I ;. , -�'., I . � . . ,i�-,;,'� ':, , , � ---, " - -- ., - . '. . � . ,.,-j'- , I , � . ' � .,.." . .,. ..- 7 .
. " .. . L �- - �" Wl - ' '�- ""�L :.."V'V�'- '(�.,-Al` ,I 7',.lj,l'l' . � '��- - .- .. -;�:! : I , ;'�V, ,, , � 17� 1 1. . " .; . .. . - .
. l., , , - - �f �, •. . , .. "VI-W.". ', , ,-�:�' , � . !,� ..., . , . - ,� ,:� : ,� ,;:�Y,�, , . . ; �... . 1 .7 .. ., I , 1. .. . ... , � 1 . . . . � . t t, . - ! ., ; " - . , ;- I , ; , .,- : - - -'t" " . . . I . I , 1.�Wl.�.:, � , � " i. - � . I '. . , . 11" , - .Wl! " .1 I . , . , , - . 4'. I "k . " . I I '., I I �,J, ;�-.k . � - . . . I , - 1. . " .
". t, , , :. 1, , . , .. ". - - X. �:,�. 14� " - . , . � -W . , . - � '... ., � ,-:."' '�':' "', '­4�',':r , . - ; ��'l . -. .
. I , , - �- - - .. ,��!� - , .. . . , j L , - � -1 i -, , -- ,
. �,' � � - , . , , '.� ! - . �.
. -. �. I.- -...-'- , , � J, ". , - - -I .. - .." .� - - -, , %-� '. " - '; " . - I I
. � -I', �'- I , ,%
. " � 4� . -� --j-,�;;,.; ,,;o -,L . .,q� ! �, ,��; , OI ,
, .. -1% r , ,j , ";rl,V I'l I•.
I . 1 .,. . � , ,.": I , �- , -�� -, , r. . 4 1 .: I �, :, . . I w f , . .',.;� - _
. , -� • I �" Z.'� - - ; A�-- �. " . " , , . . � .Y - !. - - - , - T"�-
� ). I - , " !- , " ', �� .. . i I ,
�%. : -,-� m I r. 1-� A T , , , . '.
I.". - 1. ..* r',.�.:', I - , '. I � , - , 0: - -4 ., - Z , \ . �, . -;.� - , , . , - ; r
. - * - , k Z - -i '0� � - -;.;, ..", .. , , . "I- .7 A,. -%. . " I. ;'^ �,� . I .
. . , , 1. . . � . I I .. . . , ; ,I � � -t--,,IfQl .-�� .., . '. . , -
. , -�, � . - - ,.. ..;,-, .z,. .. � . . 1, - � . -
.. I -, , - r - , , ..". ,-.j, " , g - . . , - - .. :. t:, .. - ,�. . -k -,'� 1 , , ., 'p '. ..-� ..l.l. . .
,'�� . ".,: . It.,;-, , `,�.!,
.�•
, , ',;,'zl,'�;� P, I .
,
,k .',%,:.-� ... ", ,n. , . I � .? ., I . '.
� r . . , .. I . , � I , . :, �', �.l - - , - I , �! " . ", � 1!�� ,.* . .'.;.��,-, 4: .� , , "I' A, ( .. NIT. . � I - , , ! � 1) , I . ; . . I.. -,-- .-4... I '.t.-
;Z:11- ,-, 1--, ,�.-,-
I .,.l--..--.�* f J."",�,;., �, . I 11 , :, : : , , - * l., -�. - I ki Y .'� , � , 11 ; � .:,y . _4 , ,'
- . . . I. . ", '. - - �,! �, , •.. - ,� ,.��, %. - " " , I I 1, - '. - . ! ..r : i"', - % � : " I . .
- - - -, 11 , . , .. , I '. - -- � -,I �, , - ., � , ' r'.., , " � V. ' -'�. . ''.".:.; ,% " P.� � ., . "". . - r . - - - . '� . � .. , - , , ..", , - !, , 1�
- , . : , , ' *�;. , . , 7�t - " j" .i I ? t " ,,,� y
- , ?. - -�.�7� -0 � -�-, N I I I ,*� "."..k, , ;
. , l , . �v I I - . I ��-"I .� v . -
- - : � .. � ,."? �1'.j_
I im�-. r 1. . 1 . . I 4 .
, -I,. e. , , � N I . I - , I I , ::: ... - .. - , -V -'l I `� -I'-, . I I . . � 'I" ',.r,:' '•
., , � ,_, % -; � �� � ,'� ,
-411 - , , . ; I , , � k - :i,t� �, .., .. -, - , -I-, - . , -Y , � -- 'N .., , " - I I , �lt,:,?,,.',' �.t,t ��, ­ . , L .� '� ,, �
. _,.�,', . . �ls N ,
. . . .. .1. , , I ,%. - ". . '. .. . �. � ll.,�,,�'. - I . I ... - , . . � , - t - ,' .;j" 'L 4b, , " � , . - - . ."', , . 11" - q �i, `,� . - -,. .,. ":1. " - i 1, . " %. . , I ", - , I , I . � !. . I . , 'k�; 4 �,f� ,
- . . , " I •I . I .
. . 1-3", , ,�, " z - ? �- •I , - , � •
, . .i ", ;. . .. . , , - . . � ,� . - ,�'. j - --� '�K �' , t1l -
, , . . I. . . . ,� I � � ,; -.1 -� j :"'_)�!�� T.,;�� ' 7 " "" " ' �;` -, : 'I , ; . . .
. , . . , , . - .� - ,4- . 1, !%, . " 'N., .� t4 •, I I "', ", �, , . "". 'I , . . ,� , ., r . . , � . �'- , . � .
; I 'I � -- .)V.-` , -% '. '-" , . � . , , . k , , . , _J�,:,. ..�," I ", I . . I %� � _ . � . I e . , t �
-h �' .1 ". I 1. . , , , .� _.;, .. 4. ,�
, - - - . .1 . '. , , , , - , . I I I , ­ , ,,r,,, ....... : "' .., I � . " " , ,� "?. "", ",­? . - -, ; - ::� ,� - ". -w . ... -, - ,- - .:-. -.: _ " �;, " , r, .. I .. �
- . " k , .. . , j k r- .., ( . - .. , , " � " - , �.,��,.t��!,�,., i .\ , , , : T.
i
-i i
. - '--
" - �
� "
.. v
"
k
-�---,,, , 1, lu , , -� ,,,� '' .. . -.,.,111� � ,- . -�'_.,ltl. - , , -� -;,"". Al"; "I' . - , •- , �..� - - -1 -,�,-"-; . - -r�. � ; , - , ". I
- - !.',.! ... ., ,; ";,;-;%-,%-' " ..., ­� � . - �
- � - . - .W' . . L. �, , - : ,z- , - ... �-L"-- - ! ". � , . ; ----:, -- - .
" * � - - - , , ` , , , . , -'I, " �� � - �?. ,; - ,- -f � \ - ,��
.." I ,"'V-�.' . , , .-',�f`.z,-- -, ., ,, ,
.� . ..1 ..'..". - " --V, ., . . . " I , - . ,- -: - -r. '. � - , - �-',- , `
. ', r' 'r �- �,, . , . . , r , ., ..... . , , , . . . c . ... . . , . ,:L.. .s , , . . � , , "." . ,-, I ,.,N . . . .• ­ '1-�-:,�-�_-, - 7 , . .
� � . . , . 14 •, , .. , ., . 'V 1,,% -.1% 7.1,' - -- : ! . .1, �i� I . : , . , �?-"." ;_,,I"L ., i - , , I
w., . .� - L .w I - ": 4 .... .
- - ,­ .. - " , . , ; " I ; - ,, ., .. .�j ; �., r . �y - , , -. -;- ., " . .
:71� - I , i ,it.,��:.-/ , ; " . I .
. , . ,� , -, , , . .. I . . � .
-k� - -t,z•e I - , I , ,�.: � !., I ..'r . , -,� � .,. , " . � , . . - -, , . , - - -�'.-.--7,� - . :� - .
. 71 - %� � - � - . \ � . .
- -, � : �,., , ,"-s O'� � .� , , . I ,.�- •, I y � e � -�-, � ,,- . . -NA".!, lrw.. .-�:,l ." `7-`.-.-, � ""- �', . !� , :--, 1. 1. I " � - 1 �l .!, - ',4&-.; t'?
-
�
- - ". , � Z 4 ;,, I". ,,�- . ,% �', �. , � , ,.,'. U. .-N - :.i .., •- , -r` , - , , � ,-. � ,
.,. I .r- - .., .4'. . . .. . L-. 7j, , ��`, ;.(e , � �l f - �' , �- - . �' , 3,
: , � , "'.4 ,- � —,Uj� -, -, - . ; ", , - -N , I "�Ll . ,.� �% , � i v 1. . " .1 � ..
. '. �•I �.q . I': I ..I F I .*�', , ":. 1. " '.4� I , , - .. - .; 41 . , � . � I . - , , I 1_r"'� r*.' . , �---,��. � I
�jl � -- : 4.-'N. .-I , ; vl!�� � -Ar -ls��,-�Y J". r . . I - 11 .. .i-,, , -�-"?, - ,-, , �-... �! ; 1 �1- .. � I . ,--,-':`, -
v .T
UK -
,;.- ,f . - ,�": ,, " - - " 1 . ;" " - - . r r­ -'. � � I . -, '. L � , ; ;
. . -, , .� I , 4: ", . . . , - . :
­% - 1� . . , I -.;� , , . -1� %�l zl- I l�! , -� - I I
, k * . -• � , . ! � , - - -1, I �l .. , ,�•
•
.. .- I - �
- , � I -
't ' -, -1�.��` - � " I - '. , . -,T.. - -'� ... ��i . - 4
,- - -3---$`%--� "0-- I I � I , V, T,L"'�' I . 1'%'-."�.. � 1.! 11 I . � — .(v ...i.j ., , . .. I ,.;. I -.w ,.--.-, ; -� - , `�--,- -%:, , , ,
I , — . ..
V, . I . ". , --;� . . ", Z 'r -
�." � I - ",-- , � "". - , " ! c ",.- -.', ; --� 4-` 1 � 7. ., I I , . :,. '!
" 1..:I�, — . '�. — ---t� .. , -j - —01, ;� , . .. , -,, . - ., - . , . %. 1-% �,' j -OF-47" , i
- :��Y� X,` ., - Ai � 4, .11 , -,-I I � '. . - .?;'-; ,� ,%-,�! - I
I
.
, - . . , � I - - I , � -;4..,I,., - - �-' ;:. '.-'-�Ll.' -- , - - ,t,� !,�- '1�11-" I . " # .
, �--,- --'.�r;" I . � .: , : , , . . , . - la. -
I I - - . � - ,� I - . 61 . - ,� - , ..., . .. . . -.1 . —, . -,
- � ;�-,j �'ju--'� � - """ , .. � 1, -.I,,- ... . I-
, , ;�,,',�t;.;t` .,�,:,fl
L , - . ; -� ,,,, , -, `�;,�-O,�-`i
•& I . - - - - 4 - 11 :,.� .4. /', 1. ,,, , . . . , . - � I . :: � , d '. �� -A t�,-
� . - � . .
.. - ,1%
t. - lql!pr!� _;� *.,� .1. :S",.,Z Z, O , �.. ; . �, , -
, . . -
, - . . r , ; - " �, ,
� . . .. .. ,� . , .6 , .i.-, I
-, 1� I ilail�� , ,� ;b . �M
, � - , ; . , . , I
. .
, . I . �Zllk . - . .•

oc'�F VA rF9 pG
CO 7
Michael F_ Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W_ Klimek, P. E.. Director
Division of Water Quality
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Rudcar Farms Inc
Rudcar Farms Inc
PO Box 857
Clinton NC 28328
January 9, 2003
Subject: Application for Renewal of Coverage under the State Non -Discharge General Permit
Dear Permttee:
Your facility is currently approved for operation under one of the Animal Waste Operation General Permits. These permits
expire on April 30, 2003. The Division of Water Quality (Division) staff is currently in the process of renewing these
permits and is scheduled to have the permit reissued by early April 2003. Once the permit is reissued, your facility would be
eligible for continued coverage under the reissued permit.
The Division has published a public notice regarding these renewed general permits. A copy of the draft animal
waste operation general permits and fact sheets are available at the website http:l/h2o_enr.state.nc.us/ndpu/
or by writing or calling:
Non -Discharge Permitting Unit
NC Division of Water Quality
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
Telephone number: [phone], ext. 574
In order to assure your continued coverage under the general permit. you must apply to the Division for renewal. Enclosed_
you will find a Permit Coverage Renewal Application Form. The application form must be completed and returned within 60
days from receipt of this letter. You must include a copy of your most recent Waste Utilization Plan with the application
form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil
penalty. Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-
215.1 and could result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the draft general permits, the enclosed application, or any related matter please feel free to
contact I R Joshi at 919-733-5083 extension 363.
Sincerely,
f/
Kim H. Colson, P.E.
Cc: Sampson Soil and Water Conservation District
Fayetteville Regional Office, Division of Water Quality h
Permit File AWS820035 *A
N flENR
Non -Discharge Permitting unit
1617 Mail Service Center, Raleigh, NC 27699-1617
Customer Service Center
An Equal Opportunity Action Employer
Internet http11h2o.enr.state.nc.us/ndpu
Telephone [phone] Fax [phone]
Telephone [phone]
50% recydedf10% post-consurner paper

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
Kerr T. Stevens, Director
May 10, 1999
Rudcar Farms Inc
PO Box 857
Clinton NC 28328
Attn: Robert Car �� � ' �
Dear Robert Car:
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT ANb NATURAL RESOURCES
Subject: Certificate of Coverage No. AWS820035
1 ..1 Y 1 3 1999 Rudcar Farms Inc
Swine Waste Collection, Treatment,
F,AYETTEV11 1. -E Storage and Application System
REC. OF iCE Sampson County
In accordance with your application received on March 29, 1999, we are forwarding this Certificate of
Coverage (COC) issued to Rudcar Farms Inc, authorizing the operation of the subject animal waste
collection, treatment, storage and land application system in accordance with General Permit
AWG100000. This approval shall consist of the operation of this system including, but not limited to,
the management of animal waste from Rudcar Farms Inc, located in Sampson County, with an animal
capacity of no greater than 6080 Wean to Feeder an3 the application to land as specified in the Certified
Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC,. or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This request
shall be made within 30 days of notification by the Division.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the DWQ prior to a name change or change in ownership.
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Certificate of Coverage AWS820035
Rudcar Farms Inc
Page 2
if any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual non -discharge permit by contacting the engineer listed below for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
The subject farm is located in the Fayetteville Regional Office. The Regional Office Water Quality Staff
may be reached at [phone]. if you need additional information concerning this COC or the
General Permit, please contact Dianne Thomas at [phone] ext. 364.
Sincerely,
1
Kerr T. Stevens
CC' (Certificate of Coverage only for all cc's)
Sampson County. Health Department
rFayettevilleRegional Office, Water Quality- Section
Sampson County Soil and Water Conservation District
Permit File
NDPU Files

State of North Carolina
Department of Environment and Natural Resources
Division of Water Quality
Non -Discharge Permit Application Form
(THIS FOR jLI MA Y BE PHOTOCOPIED FOR USE AS AN ORIGINAL)
General Permit - Existing Liquid Animal Waste Operations
The following questions have been completed utilizing information on file with the Division. Please
review the information for completeness and make any corrections which are appropriate. If a
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
1. GENERAL INFORMATION:
I.1 Facility Name: Rttd `'-•- -Inc Qyd cz r Fa rM
1.2 Print Land Owner's name: Rudcar Farms Inc
1.3 Mailing address: PO Box 857
City, State: Clinton NC Zip: 28328
Telephone Number (include area code): 910-564-6765
1.4 County where facility is located: Sam
L5 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a
copy of a county road map with the location of the farm identified): From Clinton take the Boykin Bridge Road SR 1214
go about 10 miles and turn right on SR 1217 farm is about 1 mile down on left.
1.6 Print Farm Manager's name (if different from Land Owner): Jim Carr
1.7 Lessee's / Integrator's name (if applicable; please circle which type is listed): Prestage Farms
1.8 Date Facility Originally Began Operation: 01/01/93
1.9 Date(s) of Facility Expansion(s) (if applicable): All/ij••
2. OPERATION INFORMATION:
2.1 Facility No.: _82_ (county number); —E (facility number)_
2.2 Operation Description: Swine operation
Ito Feeder
6080- Certified Design Capacity
Is the above information correct? N6yes; no. If no, correct below using the design capacity of the facility
The "No. of Animals" should be the maximum number for which the waste management structures were designed.
Ty2e of Swine No. of Animals Type of Poultry No. of Animals Type of Cattle No. of Animals
0 Wean to Feeder 0 Layer 0 Dairy
0 Feeder to Finish 0 Non -Layer 0 Beef
0 Farrow to Wean (# sow) 0 Turkey
0 Farrow to Feeder (# sow)
0 Farrow to Finish (# sow)
Other Type of Livestock on the farm: No. of Animals:
FORM: A`VO-G-E 5/28/98 Page I of 4 82 - 35

3
2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): 13 Required Acreage (as listed in the AWMP): 1 1.5
2.4 Number ofAaeoondl storage ponds (circle which is applicable):
2.5 Are subsurface drains present within 100' of any of the application fields? YES or dO (please circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES or f 1� (please circle one)
2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, NRCS Standards, etc.) (Swine Only)
or- NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited? Z / 9 3
What was the date that this facility's land application areas were sited? 2193
REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit
application for animal waste operations.
The CAWMP must include the following components:
3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application_
3.3.4 The soil series present on every land application field.
33.5 The crops grown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application field.
3.3.8 The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.3.10 A site schematic.
3.3.1 1 Emergency Action Plan.
3.3.12 Insect Control Checklist with chosen best management practices noted.
3.3. l3 Odor Control Checklist with chosen best management practices noted.
3.3.14 Mortality Control Checklist with the selected method noted.
3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility.
3.3.16 Operation and Maintenance Plan.
If your CAWMP includes any components not shown on this list, please include the
additional components with your submittal.
Applicalits I i als
S
FORM: AWO-G-E 5/28/98 Page 2 of 4 82 - 35

Facility Number: 82 - 35
Facility Name: Rud Car Farms Inc
4. APPLICANT'S CERTIFICATION:
RuDC,ar, FA eiws 3prc.. (Land Owner's name listed in question 1.2), attest that
this application for RoocA4z FA t;MSf Lnc. (Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will returned to mesas incomplete.
Si;nature�,Ze, ,LL+G, . 409,r Date 11—
4 P_
5. MANAGER'S CERTIFICATION: (complete only if different from the Land Owner)
(Manager's name listed in question 1.6), attest that this
application for (Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned as incomplete.
Signature
Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
FORM: AWO-G-E 5/28/98 Page 3 of 4 82 - 35

Animal Waste Management Plan Certificatioe�CVCD
Please type or print all information that does not reauire a sipnatur 'RECEIVED
General Information:
Name of Farm:
Owner(s)_ N
Mailing Ad(
r tQ
r-
M
No: I to
Z�
Farm Location: County Farm is located in: Sf%/V-5,m—
Latitude and Longitude: �� Sal 3� / 7 �' Z? �` Integrator: _Rt 5
Please attach a copy of a county road map with location identified and describe below (Be specific: road
names, I krecuons, milepost, etc.): _ a �s �o,S IZ
Ak r �S1rl
Operation Description:
Type of Swine No. o Animals
Wean to Feeder a 'go
• Feeder to Finish
• Farrow to Wean
O Farrow to Feeder
• Farrow to Finish
• Gilts
• Boars
6-1 Sf� ! Z iT Fa r
Type of Poultry No. of Animals Type of Cattle No. of Animals
❑ Layer a Dairy
El Pullets ❑ Beef
Other Type of Livestoc L- Number of Animals:
Acreage Available for Application: 13 Required Acreage: 11 - �S—
Number of Lagoons / Storage Ponds : { Total Capacity: Z73,834 Cubic Feet (ft3)
.Are subsurface drains present on the farm: YES or NO (please circle one)
If YES: are subsurface drains present in the area of the LAGOON or SPRAY FIELD (please circle one)
Owner / Manager Agreement
I (we) verify that all the above information is correct and will be upda*.ed upon chancing. I (we) understand the operation
and maintenance procedures established in the approved animal waste management plan for the farm named above and will
implement these procedures. I (we) know that any expansion to the existing design capacity of the waste treatment and
storage system or construction of new facilities will require a new certification to be submitted to the Division -of
Environmental Management before the new animals are stocked. I (we) understand that there must be no discharge of
animal waste from the storage or application system to surface waters of the state either directly through a man-made _ .
conveyance or from a storm event less severe . than the 25-year, 24-hour storm and there must not be run-off . from the =:
application of animal waste. I (we) understand that run-off of pollutants from lounging and heavy .use areas must be
minimized using technical standards developed by the Natural Resources Conservation Service. The approved plan will be
filed at the fartn and at the office of the local Soil and Water Conservation District I (we) know that any modification..
must be approved by a technical specialist and submitted to the Soil and Water Conservation District prior to
implementation. A change in land ownership requires written notification to DEM or a new certification (if the approved
plan is changed) within 50 days of a title transfer.
Name of Land
Signature:
Name of Maw
Sibnatu
AWC -- ueUS
Date: Y1_(/ 7
Date: � 1 —

Technical Specialist Certification
L As a technical specialist designated by the North Carolina Soil and Water Conservation Commission pursuant to 15A
NCAC 6F .0005, I certify that the animal waste management system for the farm named above has an animal waste
management plan that meets or exceeds standards and specifications of the Division of Environmental Management
(DEM) as specified in 15A NCAC 2H.02I7 and the USDA -Natural Resources Conservation Service (MRCS) and/or the
North Carolina Soil and Water Conservation Commission pursuant to 15A NCAC 2H,0217 and 15A NCAC 6F .0001-
.0005. The following elements are included in the plan as applicable. While each category designates a technical specialist
who may sign each certification (SD, SI, WUP, RC, I), the technical specialist should only certify parts for which they are
technically competent.
IL Certification of Design
A) Collection. Storage. Treatment Svstem
Check .the appropriate box
Existing facility without retrofit (SD or WL"P)
Storage volume is adequate for operation capacity; storage capability consistent with .waste utilization
requirements.
❑ New, expanded or retrofitted facility (SD)
Animal waste storage and treatment structures, such as but not limited to collection systems, lagoons and ponds,
have been designed to meet or exceed the minimum standards and specifications.
Name of Technical Specialist (Please Print):
Affiliation AIR (-5
Address (Agency):
Signature:
ate Work Completed:
_Phone No.: SOfd - 79 6 3
Dater
B) Land Application Site (tiVU`P)
The plan provides for minimum separations (buffers); adequate amount of land for waste utilization; chosen crop is
suitable for waste management; hydraulic and nutrient loading rates.
Name of Technical Specialist (Please Print):
Affiliatinn AIR �_5
Address (Agency):
Signature: art
C) Runoff Contrrols from Exterior Lots
Check the Appropriate box
Facility without exterior lots (SD or WUP or RC)
This facility does not contain any exterior lots.
Date Work Completed:
Za S,,�- Y Phone No.:
=J . Facilitv with exterior lots (RC)
Methods to minimize the run off of pollutants from Iounging and heavy use areas have been designed in
accordance with technical standards developed by NRCS.
Narne of Technical Specialist (Please Print):
Affiliation . %UR
Address (Agency):
Signature:
AWC -- August 1, 1997
�iVZ
Completed.
Phone No.: 726 3 _
Date: - 7
Y

"D). Application_ and Handlinz-Eguioment
Check the appropriate box
2("' Existint, or x im! ill wi existing w t ii n equipment (WUP or 1)
Animal waste application equipment specified in the plan has been either field calibrated or evaluated in
accordance with existing design charts and tables and is able to apply waste as necessary to accommodate the
waste management plan: (existing application equipment can cover the area required by the plan at rates not to
exceed either the specified hydraulic or nutrient loading rates, a schedule for timing, of applications has been
established; required buffers can be maintained and calibration and adjustment guidance are contained as part of
the plan).
Q N w e1j=ded. or existing facility without existing waste ati n eopipment fors ray irris n (1)
Animal waste application equipment specified in the plan has been designed to apply waste as necessary to
accommodate the waste management plan; (proposed application equipment can cover the area required by the
plan at rates not to exceed either the speed hydraulic or nutrient loading rates; a schedule for timing of
applications has been established; required buffers can be maintained; calibration and adjustment guidance are
contained as part of the plan).
Q New. expanded- r existing faciliW without existing waste aicati n tguipment for land 5.1geading not using
spiv irrigation. (1WUP or n
Animal waste application equipment specified in the plan has been selected to apply waste as necessary to
accommodate the waste management plan; (proposed application equipment can cover the area required by the
plan at rates not to exceed either the specified hydraulic or nutrient loading rates; a schedule for timing of
applications has been established; required buffers can be maintained; calibration and adjustment guidance are
contained as part of the plan). ,
Name of Technical Specialist (Please Print):
Affilintinn AWS
Address (Agency):
Signature:
C 4,
r/5"'X-
_Date Work Completed:
V 3 2-? Phone No.: 794o 3
Date:L��� !—
E) Odor Control. Insect Control. Mortality Management and Emerzency Action Plan (SD.
SI. tiVtiP. RC or T)
The waste management plan for this facility includes a Waste Management Odor Control Checklist, an Insect
Control Checklist, a vlortality Management Checklist and an Emergencv Action Plan. Sources of both'odors and
insects have been evaluated with respect to this site and Best Management Practices to titinimize Odors and Best
Management Practices to Control Insects have been selected and included in the waste management plan. Both the
Mortality Management Plan and the Emergency Action Plan ar c�o`m�plete and can be implemented by this facility.
Name of Technical Specialist (Please Print): C ` Wl �5✓k. ,Q� A a
Affiii
Address (Agency):.
Signature:_
Work Completed:
z Phone No.: 3'9t,2 -796
Date: /-Zf-- c77
F) Written Notice of New or Expanding Swine Farm
The fol€owing signature block is only to be used for new or expanding swine fauns that begin construction after June
21, 1996. If the facility was built before June 21, 1996, when was it constructed or last
expanded
I (we) cettifv that I (we) have attempted to contact by_certified mail all adjoining property owners and all property owners
who own property located across a public road, street, or highway from this new or expanding swine farm. The notice was
in compliance with the requirements of NCGS 106-805. A copy of the notice and a list of the property owners notified is
attached.
Name of Land Owner:
Signature: Date
Name of Manager L different from owner):
Signature:_ t ,
-kWC -- August 1, 1997
3
Date:

III. Certification of Installation
A) Collection Storalze, Treatment Installation
New, expanded or retrofitted facility (SI)
Animal waste storage and treatment structures, such as but not limited to lagoons and ponds, have been installed
in accordance with the approved plan to meet or exceed the minimum standards and specifications.
For existing facilities without retrofits, no certification is necessary.
Name of Technical Specialist (Please Print):
Affiliation Date Work Completed:
Address (Agency): Phone No.:
Signature: Date:
B) Land Application Site (WUP)
Check the appropriate box
El The cropping system is in place on all land as specified in the animal waste management plan.
0lConditional Approval: all required land as specified in the plan is cleared for planting; the cropping system
as specified in the waste utilization plan has not been established and the owner has committed to establish the
vegetation as specified in the plan by - 3o -`j .? (month/day/year); the proposed cover crop is
appropriate for compliance with the wasteutilization plan.
❑ Also check this box if appropriate
if the cropping system as specified in the plan can not be established on newly cleared land within 30 days
of this certification, the owner has committed to establish an interim crop for erosion control;
Name of Technical Specialist (Please Print):
Affiliatior.
Address (.,
Signature:.
Date Work Completed:
Z13 Z Phone No-: S -. - 9G3
Date: Z 1 - 7
This following signature block is only to be used when the box for conditional approval in M. B
above has been checked.
I (we) certify that I (we) have committed to establish the cropping system as specified in my (our) waste utilization plan,
and if appropriate to establish the interim crop for erosion control, and will submit to DEM a verification of completion
from a Technical Specialist within 15 zalendar days following the date specified in the conditional certification. I (we)
realize that failure to submit this verification is a violation of the waste mana-gement plan and will subject me (us) to an
enforcement action from DEM.
Name of Lan
Signature•m Nae of VI
Signat e•
wner•�
(if di
- �x•-Q,��� !� , _ Date: * 1 cI
from owner):
Date: Z ^ 1
AWC -- August 1, 1997 4

C) Runoff Controls from Exterior Lots (RC)
Facilitv with exterior lots
Methods to minimize the run off of pollutants from lounging and heavy use areas have been installed as specified
in the plan.
For facilities without exterior lots, no certification is necessary.
Name of Technical Specialist (Please Print):
Affiliation Date Work Completed:
Address (Agency): Phone No.:
Signature: Date:
D) Application and Handling Eauipment Installation (WUP or n
Check the approph e block
4d- Animal waste application and handling equipment specified in the plan is on site and ready for use;
calibration and adjustment materials have been provided to the owners and are contained as part of the plan.
;1 Animal waste application and handling equipment specified in the plan has not been installed but the owner
has proposed leasing or third party application and has provided a signed contract; equipment specified in
the contract agrees with the requirements of the plan; required buffers can be maintained; calibration and
adjustment guidance have been provided to the owners and are contained as part of the plan.
G Conditional approval: Animal waste application and handling equipment specified in the plan has
been purchased and will be on site and installed by (month/day/year); there is adequate
storage to hold the waste until the equipment is installed and until the waste can be land applied in
accordance with the cropping system contained in the plan; and calibration and adjustment guidance have
been provided to the owners and are contained as part of the plan„
Name of Technical Specialist (Please Print):
Affilia
Address (Agency):
Signature:
�d A CY r
Date Work Completed: /q—
Z23 Phone No.: 5��-7�4 3
Date:
The following signature block is only to be used when the box for conditional approval in III D
above has been checked.
I (we) certify that I (we) have committed to purchase the animal waste application and handling equipment as
specified in my (our) waste management plan and will submit to DEM a verification of delivery and installation
from a Technical Specialist within 15 calendar days following the date specified in the conditional certification. I
(we) realize that failure to submit this verification is a violation of the waste management plan and will subject me
(us) to an enforcement action from DEM.
Name of Land Owner:
Signature: Date:
Name of Manager (if different from owner):
Signature: Date:
E) Odor Control. insect Control and Mortality_ Management fSD. SI. WUP. RC or
Methods to control odors and insects as specified in the Plan have been installed and are operational. The
mortality management system as specified in the PIan has also been installed and is operational.
Name of Technical Specialist (Please Print):
Affiliation /v / C 5
Address (Agency):
Signature:=
tte Work Completed:
Q_ 5 Z4 Phone No.:
Date:_f�`�' 7
APVC August 1, 1997 5

Please return the completed form to the Division of Water Quality at the following address:
Department of Environment, Health, and Natural Resources
Division Of Water Quality
Non -Discharge Branch, Compliance Unit
P.O. Box 29535
Raleigh, NC 27626-0535
Please also remember to submit a copy of this form along with the complete Animal Waste
Management Plan to the local Soil and Water Conservation District Office and to keep a copy
in your files with your Animal Waste Management Plan.
AWC -- August 1, 1997 6

r
z x ay s
�I 0, . ti M1 q'43 por11 �'•7� +'al a �Y P e• �'"�,- rarars°a / r---�_� -�
r In > t
Ir'41r1M] apart 9 IW 04 rr �� :)r /"�/emu 1
OW
PkorYyi 7.0 SAP �' g M1 •• {{ ' 4 /,ter !
0
7 P i�Pi J• .� 4✓ K r'I 1
fr ,� • ^ 1, V +t i ,� $ '3 M. �Y y . G4p nn
•4 L' p�4 !.7 04 .I rr ] � � .I 7
7 PY ! t day _ dW1 '.1�. D, i• a• is ' .��n+. '+nr q n 0°a wYaOti�
44,.
�^ �� T L� *.lL � �1° ak �1 + y^' "�:?•: 4i 7 _ � 11. ��
iA!
r—
�y
� p'i, 7, � � � .� ' 'I y�1•, g �V � 1,tIn4tL11 � °p � V � r° + 9ypD4oa � nr rn
. aY yaaul ti,e. Y1 �} rc � r1 •�` 1',` �•'' � 97 6 �J'�. •r. � I.. ° � �FV � � �
`!, '°Q's� rl � � �1 1ti Y �e Y »�; � t .. �..�'+ .AEU' �S a o -• of
! f ��' t �Q� � � � �J "° poor` �q o • - g cti .}, � � rJi ��• _ � t by • oo r ��
^ y,7 •, ..' � .+ n � a4,H>ra'1D � f ° y+ � ,. � J �4 f. � t rt � P. ; �a
`�Jf °• 11a J p '� ° rY OnY iilYa liM •1 y x w
'1 , °"�r M1 4 a � t .�> �fp s a �.� gj r � � .. 1'`oi•�l * � o C °�• o.t � �_' r * .)'
51
{/ a �p.7� jtK ^s�I r�MI a i '4�• � � P �r[. ,R a � � • 4'; 41
'��y1 � n 1 � � rJ•r I
+-1 11 °Y r)Yik° � � P. 4: � �-Il � ♦q�y Lp �'� � n°I f na
.l R� r 17ty .1
�� ar4.� � � � { �1 q O IINI `k4 j4 � i�4p,if `,� �p 5p ^I' I� n} (/ � rq�1, b • °.R � �=�y' �_
-'..1 ,a $ 4y� • f it • i, +! �� � h - ^°i � +� - `� f. S.. i f "`�. N` �
=tor

9
VT t, I
��' ^y i / r, "ol`Yl ,...
Z- '"•'' +� `;C,i.,{•, ntt +,II lilt ` n' � -r r I'��I�101hl117 � JJ ;� � '
n ` .r 1 t .,{,�,11Pr
'T t

WASTE IITILIZATION PLAN
Producer: RUDCAR FARMS INC.
RZ-03
Location: P.O. BOX 857 f-�� r
CLINTON NC 28442
Telephone: 910-56�4-6765 % 6-n f--Vf-
tmType Operation: Exisng W to Feeder Swine
Number of Animals: 6$$8.0o pigs
(Design capacity) 6090.Oe Cc *0191
STORAGE STRUCTURE: Anaerobic Waste Treatment Lagoon
APPLICATION METHOD: Irrigation G. 6c,M1J Ci.r 97PAI
g13a / 19 'd4 pit. Pe,t�
Y130 '�/9C'`•rr l�wncr
RaQ•.45�`c��
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops
in the fields where the waste is to be applied.
'his waste utilization plan uses nitrogen as the limiting nutrient.
,dste should be analyzed before each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply
more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall be applied to land eroding at less than
5 tons per acre per year. Waste may be applied -to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on saturated soils, when it is raining,
or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed
under DWQ regulations.
Page: I

ANIMAL WASTE UTILIZATION PLAN
S. Wind conditions should also be considered to avoid drift and
downwind odor problems.
6. To maximize the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more than 30
days prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. If
you choose to change methods in the future, you need to revise this
plan. Nutrient levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from your
waste management facility. In some cases you may want to have plant
analysis made, which could allow additional waste to be applied.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
?his waste utilization plan, if carried out, meets the requirements
for compliance with 15A NCAC 2H .0217 adopted by the Environmental
Management Commission.
AMO OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
f� ¢1;� 9 9 G C d-13019 Itcif Y/��9 i Z4 32 5//3a/y 9
6080 pigs x .40 tons waste/pigs/year = 24 zF ons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
GG 4130191 GC 4.130147
6080 pigs yXg9
48 lbs PAN/pigs/year = lbs. PAN/year
Applying the above amount of waste is a big job. You should plan
time and have appropriate equipment to apply the waste in a timely
manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
Page: 2

ANIMAL WASTE UTILIZATION PLAN
** Acreage figures may exceed total acreage in fields due to
overseeding.
* lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and 2 above:
CROP CODE
CROP
UNITS
PER UNIT
BP
SG
HYBRID BERMC3DAGRASS-PASTURE
SMALL GRAIN OVERSEEDED
TONS
AC
50
50
TABLE 1
TABLE 2
TOTAL
**
TOTALS FROM TABLES 1 AND 2
ACRES
LBS AW N USED
13
3315
0
0
13
3315
* BALANCE
GG 411 009
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.
Page_ 5

• ANIMAL WASTE UTILIZATION PLAN
Producer: RUDCAR FARMS INC.
Location: P.O. BOX 857 --�` r d.{`fv� r ��
CLINTON NC 28441 � Y� ^, � jrj
Telephone: [phone] Hff°`� t
CGliG'j,I n,�
Type Operatic_i : Existing W to Feeder Swine -rs hw"t
Number of Ani-als: 6080.00 pigs `
(Design Capacit_)
STORAGE STRUC_'11RE: Anaerobic Waste Treatment Lagoon
APPLICATION Irrigation
The waste frc:. your animal facility must be land applied at a
specified raL: .-o prevent pollution of surface water and/or
groundwater. .'he plant nutrients in the animal waste should be used
to reduce th:. ltmount of commercial fertilizer required for the crops
in the fields -.i-ere the waste is to be applied.
'his waste uic.]_ization plan uses nitrogen as the limiting nutrient.
,daste should analyzed before each application cycle. Annual soil
tests are sty _,gly encouraged so that all plant nutrients can be
balanced for ::alistic yields of the crop to be grown.
Several fac-c -, are important in implementing your waste utilization
olan in orde_. --o maximize the fertilizer value of the waste and to
ensure that -_s applied in an environmentally safe manner:
1. al. _s apply waste based on the needs of the crop to be
grc:_. and the nutrient content of the waste. Do not apply
mot nitrogen than the crop can utilize.
2. So_ =.ypes are important as they have different infiltration
_�..: leaching potentials, cation exchange capacities, and
u... -able water holding capacities.
3. '-,io-- :_,ily waste shall be applied to land eroding at less than
3 :_s per acre per year. Waste may be applied to land
e---c .ng at 5 or more tons per acre annually, but less than
0 -::s per acre per year providing that adequate filter
:.s are established.
4. Do apply waste on saturated soils, when it is raining,
of.,,gin the surface is frozen. Either of these conditions
ma,. ,. �sult in runoff to surface waters which is not allowed
Uln:l DWQ regulations.
Page: 1

• ANIMAL WASTE UTILIZATION PLAN
5. Winci conditions should also be considered to avoid drift and
dog: i, wind odor problems.
5. To maximize the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more than 30
day..: prior to planting a crop or forages breaking dormancy.
lnj-sting the waste or disking will conserve nutrients and
red,,:ce odor problems.
This plan is :,aced on the waste application method shown above. if
you choose to change methods in the future, you need to revise this
plan. Nutrie:.c levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on
cypical nu4Yi.-:-it content for this type of facility. Acreage
reauiremen�s :.should be based on the waste analysis report from your
waste manage m-..rit facility. In some cases you may want to have plant
analysis made:, which could allow additional waste to be applied.
Provisions s-P.11 be made for the area receiving waste to be flexible
so as to ac=o--:nodate changing waste analysis content and crop type.
Lime must be .%.splied to maintain pH in the optimum range for specific
crop product
his waste u.::.1 --"za-1 ion plan, if carried out, meets the requirements
for compli.anc-._ with 15A NCAC 2H .0217 adopted by the Environmental
Managemenz CC.:i li scion.
AMOUNT G_' WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
6055 pigs x ..:D tons waste/pigs/year = 2434.4 tons
AMOUNT PTLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
503E pigs x .'8 lbs PAN/pigs/year = 2921.28 lbs. PAN/year
;�p,clving try. sbove amount of waste is a big job. You should plan
Z.iiile and hav appropriate equipment to apply the waste in a timely
ma_,ner.
The followi::cJ acreage will be needed for waste application based on
Ghe crop to grown, soil type and surface application.
Page: 2

ANIMAL WASTE UTILIZATION PLAN
TABLE 1: ACRES OWNED BY PRODUCER
TR-;%CT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
Ail N
PER AC
AC
USED
-----
or
-------
APPLY
RESID.
APPLIC
METH
N
TIME
2770'
11
Wc"B
BP
4.1
205
0
13
2665
I
MAR--OCT
2776 1-11
SG E1 150 IO 113 16SO
I jSEP-MAY
I
TOTAL13315
- - Indica��.s that this field is being overseeded (i.e.
intero).j::nted) or winter annuals follow summer annuals.
:iOTz The ao�):_icator is cautioned that P and K may be over applied
while i;.:_eting the N requirements. In the future, regulations
may rec{_,ire farmers in some parts of North Carolina to have a
nutrie_.-_. management plan that addresses all nutrients. This
plan o:_.ly addresses nitrogen.
Page: 3

ANIMAL WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agre::ment with adjacent landowners must be attached.)
(Req�.red only if operator does not own adequate land.
See required specification 2.)
:OIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
_):T2_ MINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
--------
APPLY
RESID.
APPLIC
METH
N
TIME
TOTAL10
Tndicat--.. chat this field is being overseeded (i.e. interplanted) or
winter E,_�_-Iuals follow summer annuals.
in intE:--planted fields (i.e. small grain, etc, interseeded
in berr._idagrass), forage must be removed through grazing,
hay arc./or silage. Where grazing, plants should be grazed
when c_.:r reach a height of six to nine inches. Cattle
snould removed when plants are grazed to a height of four
aches- Tn fields where small grain, etc, is to be removed
-or ha,. (Dr silage, care should be exercised not to let small
grain reach maturity, especially late in the season (i.e.
April c_ May). Shading may result if small grain gets too
high a_ this will definitely interfere with stand of
bermu(dE :---ass. This loss of stand will result in reduced
yields ind less nitrogen being utilized. Rather than
cuttinc_ small grain for hay or silage just before heading as
is the ornal situation, you are encouraged to cut the small
grain . slier. You may want to consider harvesting hay or
silage ;o to three times during the season, depending on
t�M2 :! 1 grain. �S planted �n the =all.
Tay ic_.:= time to interplant small grain, etc, is late
Se- ot.em: or early October. Drilling is recommended over
brcadcl -ins. Bermudagrass should be grazed or mowed to a
heigh4 := about two inches before drilling for best results.
Page: 4

ANIMAL WASTE UTILIZATION PLAN
** Acreage figures may exceed total acreage in fields due to
oversee: Ing.
* lbs AW ? (animal waste nitrogen) equals total required nitrogen
less an_ commercial nitrogen (COMM N) supplied.
The follow---_< legend explains the crop codes used in tables 1 and 2 above:
CROP CODE
f BP
SG
CROP
?� , -, D BERMUDAGRASS--PASTURE
SM:--::.. GRAIN OVERSEEDED
TABU -
TABLE 2
TOT
TOTALS FROM TABLES 1 AND 2
ACRES
LES AW N USED
13
3315
0
0
13
3315
* BALANCE
-393.72
UNITS I PER UN I T
TONS 50
AC 1 50
-------------------
**_ This nu- must be less than or equal to 0 in order to
utilize the animal waste N produced.
Page. 5

ANIMAL WASTE UTILIZATION PLAN
*** This nu: war must be less than or equal to 0 in order to fully
utilize_ 4e animal waste N produced.
Acres shown :n each of the preceding tables are considered to be the
usable acres excluding required buffers, filter strips along ditches,
odd areas u: Ae to be irrigated, and perimeter areas not receiving
full applicn: sn rates due to equipment limitations. Actual total
acres in the 7Alds listed may, and most likely will be, more than
the acres shcan in the tables.
See attached rap showing the fields to be used for the utilization of
animal waste.
SLUDGE APP I C' L ON :
The waste utilization plan must contain provisions for periodic land
application o: sludge at agronomic rates. The sludge will be nutrient
rich and will _:quire precautionary measures to prevent over application
of nutrients ci ether elements. Your production facility will produce
approximately ;52.536 pounds of plant available nitrogen per year in the
fudge.
f for; remove 3ne sludge every 5 years, you will have approximately 2312.08
pounds of PA _j utilize. Assuming you apply this PAN to hybrid
bermudagrass _ :gland at the rate of 300 pounds of nitrogen per acre, you
will need 7.7C ):3333333 acres of land. If you apply the sludge to corn at
the race of _pounds of nitrogen per acre, you will need 18.50144 acres
of land. Pin: _ be aware that these are only estimates of the PAN and
land needed. _.zual requirements could vary by 25% depending on your
sludge waste _ ilysis, soil types, realistic yields, and application
me t Aods .
—=___CATION OF WASTE BY IRRIGATION
The irriganic:
soil an the t1
rate is limi&
Lex:.ure, wand_
should non en
time of irric._
nhe nitrogen :
Tf surface =_
1s the Yes
.pan an iryiy
shown in T a±
_plication rate should not exceed the intake rate of the
of irrigation such that runoff or por_ding occurs. This
by initial soil moisture content, soil structure, soil
1 oolet size, and organic solids. The application amount
Q the available water holding capacity of the soil at the
.ion nor should the plant available nitrogen applied exceed
.ids of the crop.
anion is the method of land application for this plan,
.:3ibilzty of the producer and irrigation designer to ensure
.on system is installed to properly irrigate the acres
and 2. Failure to apply the recommended rates and
Page: 6

ANIMAL WASTE UTILIZATION PLAN
amounts of r_ --ogen shown in the tables may make this plan invalid.
The followinc- ,_able is provided as a guide for establishing application
rates and Gtr:. -_cs.
Tract I Field
2776 11
2776
I -:1
I i
cif Type I
aS l
� I
Crop
(Application RatelApplic. Amount
i (in/hr) l (inches)
BP 1 0.60
I SG
*0.96
x This -- .'-e maximum application amount allowed for the soil
assu-.- the amount of nitrogen allowed for the crop is not over
appli:.c. In many situations, the application amount shown cannot
be avD� because of the nitrogen limitation. The maximum
applic, on amount shown can be applied under optimum soil
condi-,.- :s.
Your faci e: -s designed for 180.00 days of temporary storage and
the tempora_ storage must be removed on the average of once every
6.00 mont^:3. =n no instance should the volume of the waste be stored
in your sir: ..re be within the 25 year 24 hour storm storage or one
foot of fr.=_- .�rd except in the event of the 25 year 24 hour storm.
It is the �:lsibility of the producer and waste applicator to
ensure tha._ spreader equipment is operated properly to apply the
correct rar .-o the acres shown in Tables 1 and 2. Failure to apply
the recor,:r.,.: rates and amounts of nitrogen shown in the tables may
make this invalid.
call your :-.ical specialist after you receive the waste analysis
report fc "stance in determining the amount of waste per acre and
the prope,: J -icaticn rate prior to applying the waste.
NARRATIVE OF OPERATION
Page: 7

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal :aste shall not reach surface waters of the state by
runoff, !rift, manmade conveyances, direct application, or
direcE -scharge during operation or land application. Any
dischai of waste which reaches surface water is prohibited.
2. There st be documentation in the design folder that the
produc= either owns or has an agreement for use of adequate
land c: :ich to properly apply the waste. If the producer does
not own . equate land to properly dispose of waste, he/she shall
provide copy of an agreement with a landowner who is within a
reason: e proximity, allowing him/her the use of the land for
waste " lication. It is the responsibility of the owner of the
facili: to secure an update of the Waste Utilization Flan when
there j a change in the operation, increase in the number of
animal:_ method of utilization, or available land.
3. Anima_
-aste shall be applied to meet, but not exceed, the
nitrogL
_seeds for realistic crop yields based on soil type,
availst
moisture, historical data, climatic conditions, and
level c
management, unless there are regulations that restrict
the ra:
..f application for other nutrients.
Ar:imE:
ante shall be applied to land eroding less than 5 tons
per ac_
per year. Waste may be applied to lard that is eroding
at 5 ci
ore tons, but less than 10 tons per acre per year
providi
grass filter strips are installed where runoff leaves
the =_..
,. (See FOTG Standard 393 -Filter Strip)
3_ Odors
n be reduced by injecting the waste or disking after
waste t
_ication. Waste should not be applied when there is
dancer
drift from the irrigation field.
6. When :�,al waste is to be applied on acres subject to
floodin it will be soil incorporated on conventionally tilled
croola:- When applied to conservation tilled crops or
grass_, the waste may be broadcast provided the application
does T_c occur during a season prone to flooding. (See "Weather
and Clz ie in North Carolina" for guidance.)
7.iq_ ante shall be applied at rates not to exceed the soil
inf_+12 ion rate such that runoff does not occur offsite or tc
surfac_ _._ers and in a method which does not cause drift from
the S11 luring application. No ponding should occur in order
to con7 - odor or flies.
a. aste shall not be applied to saturated soils, during
rain vents, or when the surface is frozen.
9. ,V _:;�:.. aste shall be applied on actively growing crops in such
a mar_._ Kau the crop is not covered with waste to a deoth that
would ibis growth. The potential for salt damage from animal
wasie nld also be considered.
Page: 8

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
10. Wastw ionrients shall not be applied in fall or winter for
spring lanced crops on soils with a high potential for
leach2 waste nutrient loading rates on these soils should be
held Y a minimum and a suitable winter cover crop planted to
take released nutrients. Waste shall not be applied more
than days prior to planting of the crop or forages breaking
dorman
11. Any : swine facility sited on or after October 1, 1995 shall
compl Loh the following: The outer perimeter of the land area
onto v ch waste is applied from a lagoon that is a component of
a swin farm shall be at least 50 feet from any residential
props. boundary and from any perennial stream or river (other
than x irrigation ditch or canal. Animal waste other than
swino ste from facilities sited on or after October 1, 1995),
shall n be applied closer than 25 feet to perennial waters.
(Sep V ndard 393 - Filter Strips).
12. Aninr :Taste shall not be applied closer than 100 feet to
wells.
13. AnfwE .paste shall not be applied closer than 200 feet of
dwell a other than those owned by the landowner.
14. WaP7: tall be applied in a manner not to reach other property
and ct is right-of-ways.
15. Animc :paste shall not be discharged into surface waters,
draAL .ays, or wetlands by a discharge or by over -spraying.
Animal ..ste may be applied to prior converted cropland provided
the,. : been approved as a land application site by a
"Esc:: ._ specialist". Animal waste shall not be applied on
grasso naterways that discharges directly into water courses,
and __per grassed waterways, waste shall be applied at
agra7v : rates in a manner that causes no runoff or drift from
the si
15. Do;,n=
and industrial waste from washdown facilities,
shoal
toilets, sinks, etc., shall not be discharged into the
anima,
nee management system.
17. A. pro
.hive cover of appropriate vegetation will be
eszat!
ied on all disturbed areas (lagoon embankments, berms,
pips: .
;, etc.). Areas shall be fenced, as necessary, to
prorou
the vegetation_. Vegetation such as trees, shrubs, and
other
)dy species, etc., are limited to areas where considered
awnyoj
vie. Lagoon areas should be kept mowed and accessible.
Rerm s
. structures should be inspected regularly for evidence
of :_._-.
;n, leakage or discharge.
Page:

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
13 . Tf a-;lal production at the facility is to be suspended or
termI r .ed, the owner is responsible for obtaining and
imple Ming a "closure plan" which will eliminate the
possib-._ity of an illegal discharge, pollution and erosion.
-9. waste )andling structures, piping, pumps, reels, etc., should
be in: :ected on a regular basis to prevent breakdowns, leaks,
anc lls. A regular maintenance checklist should be kept on
sice.
20. Animal waste can be used in a rotation that includes vegetables
anc: -Dc. _er crops for direct human consumption. However, if
anima_ waste is used on crops for direct human consumption it
shcul� only be applied preplant with no further applications of
an i m. = waste during the crop season.
21. H'_Cnl_ visible markers shall be installed to mark the top and
botto: elevations of the temporary storage (pumping volume) of
all ;te treatment lagoons. Pumping shall be managed to
main_- .n the liquid level between the markers. A marker will
be _-c _ired to mark the maximum storage volume for waste
scc--ac. . ponds.
22. Waste :'mall be tested within 60 days of utilization and soil
snail ,e tested at least annually at crop sites where waste
prcd� s are applied. Nitrogen shall be the rate - determining
eleme: Zinc and copper levels in the soils shall be
moni ed and alternative crop sites shall be used when these
metal:_ approach excessive levels. pH shall be adjusted for
or)z crop production and maintained. Soil and waste
ancl;: s records shall be kept for five years. Poultry dry
wasc.= � nl i cation records shall be maintained for three ( 3 )
years Waste application records for all other waste shall be
maI.__: --ed for five (5) years.
23. Dead _ .imals will be disposed of in a manner that meets North
Carol a regulations.
Page: 10

ANIMAL WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of F : _­m : RUDCAR FARM
Owner/Mali iger Agreement
I (we) understand and will follow and implement the specifications
and the c.)_ration and maintenance procedures established in the
approved 1.nimal waste utilization plan for the farm named above. r
(we) knot: that any expansion to the existing design capacity of the
waste tr .tment and storage system or construction of new
aciliti� will require a new certification to be submitted to the
North Ca- ;l i na Division of Water Quality (NCDWQ) before the new
animals stocked. I (we) also understand that there must be no
discharge of animal waste from this system to surface waters of the
state frc. a storm event less severe than the 25--year, 24-hour
storm. approved plan will be filed on -site at the farm office
and at t_.= office of the local Soil and Water Conservation District
and will e available for review by NCDWQ upon request.
Name of :-.cility Owner: RUDCAR FARMS INC.
(Please pr.
Signatur,F . C ate: 12�f y 7
Name of ?,_ _nager (If different from owner):
Signatur_
Date:
Name of : a -son Preparing Plan: (please print)Wilson Spencer
.:�ffiliatl :_:MRCS
yddress gency):
Signatur
Phone No.
84 County Complex Rd.
Clinton NC 28328
r
Date :
f
f�
Page: 11

90 V)
41 IFFY' f!
.1se
i f�4�
'M
fen.
L.q
V. '."4'­
4.
(Zk
TO
'T
It
A rMW t "i
��F•'
47t
�6A
t L
1M.,
- IF
Ise 1 41 .
Lit
"Al
Q! Awl
;' A.6,
Apt .-t?
ANN,
ANFo
2b-
44
-fig
32 IP
�'Fo(j ' * 11 - , f. .
tip r• rf,
OF
Tg
4
1Z W':D
Yoe
T I
77 1 TIN
Now
4k
L4 311 ­t' �7.'t

T-v
IA
JJ
`IQ

SAMPSON COUNTY
• EMERGENCY ACTION PLAN
DIVISION OF WATER QUALITY ( DWO ) 910--486-- 154 1
EMERGENCY MANAGEMENT SERVICES (EMS) 910-592-8996
SOIL & WATER CONSERVATION DISTRICT (SWCD) 910-592-79f.3
NATURAL RESOURCES CONSERVATION SERVICE (NRCS) 910-592-7963
COOPERATIVE EXTENSION SERVICE (CES) 910-592-7161
This plan will be implemented in the event that wastes from your
operation are leaking, overflowing, or running off the site. You should
NOT wait until wastes reach surface waters or leave your property to
consider that you have a problem. You should make every effort to
ensure teat this does not happen. This plan should be posted in an
accessible location for all employees at the facility. The following
are some action items you should take.
I. Stop the release of wastes. Depending on the situation, this may
or ma;• not be possible. Suggested responses to problems are
listec below:
A. Lauoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam, any
permanent alteration of the dam should be approved by a
qualified technical specialist.
t.. Pump wastes to field at an.acceptable rate.
c. Stop all additional flow to the lagoon -hold waste in the
house if possible.
c_. Gall a pumping contractor.
i_. Make sure no surface water is entering lagoon.
S. Runoff from waste application field -action include:
a. Immediately stop waste application.
I..,. Create a temporary diversion or berm to contain the
waste.
c.. Incorporate waste to reduce further runoff.
0. Evaluate and eliminate the reason(s) that caused the
runoff.
e. Evaluate the application rates for the fields where
runoff occurred.
C. Le-kage from the waste pipes and sprinklers -action include;
Stop recycle (flushing system) pump.
r,. Stop irrigation pump.
Close valves to eliminate further discharge.
Repair all leaks prior to restarting pumps.
D. l_e;:,kage from flush system, houses, solids separators -actions
�r1.__Iude:
Stop recycle (flushing system) pump.
D. Stop irrigation pump.
Make sure no siphon effect has been created.
c}. Stop all flows in the house, flush systems, or solid
separators.
Repair all leaks prior to restarting pumps.

E. Leakage from base or sidewall of lagoon. Often this is seepage
as opposed to flowing leaks -possible action:
a. Dig a small sump or ditch to catch all seepage, put in a
submersible pump, and pump back into lagoon.
b. If holes are caused by burrowing animals, trap or remove
animals and fill holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side
walls and the lagoon bottom as soon as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
L. Approximately how much was released and for what
duration?
c,. Any damage noted, such as employee injury, fish kills, or
property damage?
e . Did the .spill. leave -the .proper. ty?
e. Does the spill have the potential to reach surface
raters?
f. Could a future.rain event cause the spill to reach
surface waters?
g. Are potable water wells in danger (either on or off of
the property)?
How much reached surface waters?
3. Contact appropriate agencies.
During normal business hours, call your DWO (Division of
Water Quality) regional office, at 910-486-1541, after
hours, emergency number:919-733-3942. Your phone call
should include: YOUR NAME, FACILITY, TELEPHONE NUMBER,
THE DETAILS OF THE INCIDENT FROM ITEM #2 ABOVE, THE
EXACT LOCATION OF THE FACILITY, AND THE LOCATION OR
DIRECTION OF MOVEMENT OF THE SPILL, WEATHER AND WIND
CONDITIONS. THE CORRECTIVE MEASURES THAT HAVE BEEN UNDER
TAKEN, AND THE SERIOUSNESS OF THE SITUATION.
L. If spill leaves property or enters surface,waters, call
local (EMS) Emergency Management Services at
910-592-8996.
c. Instruct EMS to contact local Health Department.
d. Contact local SAMPSON Soil and Water Conservation
District (SWCD), Natural Resources Conservation Service
(NRCS) office at 910-592-7963 and Cooperative Extension
Service (CES) at 910-592-7161 for advice/technical
assistance.
4. If noi,e ❑f the above works call 911 or the sheriffs Department
and explain your problem to them and ask that person to contact
the proper agencies for you.

5. Contact the contractor of your choice to begin repair of the
problem to minimize off -site damage.
a. Contractors Name: tcs crrtis _�7 ��� �roS
b. Contractors Address: a• x 3
_C 3a
c. Contractors Phone:
b. Contac, the technical specialist who certified the lagoon (NRCS,
Consulting Engineer, etc.)
a. Name:
b. Phone: ��ls9s-577�
7. Implemt--nt procedures as advised by DWO and technical assistance
agencit_,s to rectify the damage, repair the system, and reassess
the wa,,te management plan to keep problems with release of wastes
from happening again.
B. If you are a contract swine grower associated with a swine
compan.. integrator, contact the company representative at
1-910--592-5771

Insect Control Checklist for Animal Operations
Source Cause BMPs to Control insects Site Specific Practices
Llauld Svslems
Flush Gutters • Accumulation of solids
Gr Flush system. is designed and operated
sufficiently to remove accumulated solids from
gutters as designed,
fYd Remove bridging of accumulated solids at
discharge
Lagoons and Fits • Crusted Solids
Elf Maintain lagoons, settling basins and pits where
pest breeding is apparent to minimize the
crusting of solids to a depth of no more than 6 -
8 Inches over more than 30% of surface.
Excessive Vegetative • Decaying vegetation
61 Maintain vegetative control along banks of
Growth
lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along water's edge on impoundment's perimeter.
Dry Systems
Feeders • Feed Spillage ❑ Design, operate and maintain feed systems (e.g.,
bunkers and troughs) to minimize the
accumulation of decaying wastage.
Cl Clean up spillage on a routine basis (e.g., 7 - 10
day interval during summer; 15-30 day interval
during winter).
Feed Storage • Accumulations of feed residues O Reduce moisture accumulation within and
around immediate perimeter of feed storage
areas by insuring drainage away from site
and/or providing adequate containment (e.g.,
covered bin for brewer's grain and similar high
moisture grain products),
❑ Inspect for and remove or break up accumulated
solids in tiller strips around feed storage as
needed.
AMIC - November 11, 1996, Page 1

Swine Farm Waste Management Odor Control Checklist
Source Cause ' ••IIMPs to Minithize Odor Site Speciric Practices
Farmstead Swine production . Vegetallve-or wooded buffers;
Oew�Recommendcd,.b'est'management practices;
O."Cood Judgment and commori sense
Animal body surfaces . Dirty manure -covered animals D ' floors
Floor surfaces Wet manure -covered floors Slotted floors;
Gr Waterers located.over slotted floors;
Cl Feeders at high end of solid floors;
❑ c manure buildup from floors;
Un crflaorvcntllation fordtying
Manure collection pits
. Urine;
Frequent mauure'removal by flush, pit recharge,
• Partial microbial decomposition
or scrape;
�i
O .Underfloor venillallon
Ventilation exhaust fans
Volatile gases;
ef F n maintenance;
Dust
( dent air movement
-indoor surfaces
Dust
gr Waslidown between groups of animals;
❑ Feed additives;
O] . er covers;
Feed delivery downspout extenders to feeder
-
covers
Flush tanks
• Agitation of recycled lagoon
0 Flush lank'covere
liquid while tanks are filling
p Extend fiil lines to near bottom 6f tanks with
-
anti-sl hon vents
Flush alleys Agitation during wastewater. I] Underfloor flush with underfloor ventilation
conveyance
Pit recharge points. Agitation of recycled lagoon ❑ Extend recharge lines to bear bottom of pits
liquid while -pits are filling with anti -siphon vents
Lift stations Agitation during sump tank d Sump tank covers
filling and drawdown
Outside drain collection Agitation during wastewater Ci Box covers
o:! junction bones conveyance.
A146C - November 11, 1996, Page'3

Source Cause BMPs to Minimize Oddr Site Specific Practices
End'of drainpipes at
Agitation during wastewater
❑ Extend discharge point of pipes underneath
Jagoon
conveyance
lagoon liquid level
Lagoon surfaces ,
•. -Volatile gas emissions;
Proper lagoon liquid capacity;
• fllological mixing;
0010cotrccl lagoon startup procedures;
• Agitation
inimum surface area -to -volume ratio;
2minimum
:c
agitation when,pumping;
O Mechanical aeration;
❑ . Proven biological additives
Irrigation sprinkler
• High pressure agitation;
I gate on dry dayrwith'linle or no wind;
nozzles
0 Wind drill '
imum recommended operating pressure;
Pump Intake near lagoon liquid surface;
❑ Pump from second -stage lagoon
.Storage tank or basin
• Partial microbial decomposition;
❑ Bottom or midlevel loading;
surface
• Mlxin while feliin
❑ T k
g $ an covers,
• Agitation when emptying ❑ Basin surface male of solids;
Cl
Proven biological additives oroxldanis
Settling,basin surface •
Partial microbial decomposition;
❑
Extend drainpipe outlets underneath liquid
•
Mixing while filling;
level;
•
Agitation when emptying
❑
Remove settled solids regularly
Manure, slurry or sludge •
Agitation when spreading;
❑
Soil injection of slurry/sludges;
Spreader outlets 0
Volatile gas emissions
❑
Wash residual manure from spreader aller use;
Cl
Proven biological additives or oxidants
Uncovered manure, - •-
Volatile gas emissions while
❑
Soil injection ofsiurry/sludges
slurry or sludge on field
drying
0.
Soil Incorporation wlthin-48 firs.;
aui•f aces
❑
- Spread In thin uniform layers fbrrapid drying;
..
❑
Proven biological additives or oxidants
Dead animals •
Carcass decomposition
J2111roperdispositlon
of carcassus
Dead animal. disposal o
. Carcass decomposition ;
Cl
C iplete covering of carcasses In burial pies;
pits
Proper location/comiruction of.disposal pits.
Incinerators .
Incomplete combustion'
❑
Secondary static burners
AM4t lovember 1 f,,1996, Page 4

Source Cause BMPs to Minimize Odor Site Specific Practices
Standing water around • Improper drainage; Qr Grade and landscape such that water drains
facilities . Microbial decomposition of away from facilities
organic matter '
Manure trucked onto Poorly maintained access rondo Farm access road maintenance .
public roads from farm
access
Additional Information : Available From
Swine-Manurc Management ; .0200'Rulc/BMP Packet NCSU, County Extension Center
Swine Production Farm Potential Odor Sources and Remedies ; EBAE Fact Sheet. NCSU - BAE
Swine Production Facility Manure Management: Pit Recharge- Lagoon Treatment ; EBAE 128-88 NCSU - BAE
Swine Production Facility Manure Management: Underfloor Flush - Lagoon Treatment ; •EBAE 129-88 NCSU - DAE
Lagoon Design and Management for Livestock Manure Treatment and Storage ;, EBAE 103-83 . NCSU - BAE
Calibration of Manure and Wastewater Application Equipment ; EBAE Fact Sheet NCSU - BAE
Controlling Odors from Swine Buildings; PIH-33 NCSU - Swine Extension
Environmental Assurance Program ; NPPC Manual NC Pork Producers Assoc
Options for Managing Odor ; a report from',the Swine Odor Task Force NCSU Agri Communications
Nuisance Concerns, in Animal Manure Management: Odors and Flies ; 11110107, 1995 Conference Proceedings Florida Cuoperudye. Extension
AMOC - November. 11, 1996, Page 5

Mortality Management Methods
(check which method(s) are being implemented)
❑ i3c;'al three feet beneath the surface of the ground within 24 hours after
,:nowledge of the death. The burial must be at least 300 feet from any flowing
trc m or public body of water.
.endering at a rendering plant licensed under G.S. 106-168.7
❑ ('o:nplete incineration
❑ 1 the case of dead poultry only, placing in a disposal pit of a size and design
._oproved by the Department of Agriculture
❑ ;, av method which in the professional opinion of the State Veterinarian would
�..: possible the salvage of part of a dead animal's value without endangering
r.• ni n or animal health. (Written approval of the State Veterinarian must be
a-a--hed)
December 18, 1996

'_•_ r : i F: EAR11 Coun ty : SAMF'SON F)a tP l i / i �� i 93
i_tar,ce to nearer'_ residence (other than owner)
"EAD ST��TE !._ VE-- WE I IGHT
if sc}ws :.rt c;Vj t.o f�ni=h) X 1.417 1bi. - ? 17j
!fa, -w to fee--dFr1
!-s"_•ac+ r f ,..; .. __ h i re C>n l y) 1 Y' '. b
_Ckk _. tr
-,T.'a;_ :STEADY STATE LIVE WE I. ��HT
'-x':T.D F,'.!.--ATS iEN F VVL +JI!E OF i._A3`10N
V ?1;rr�- = IS:400 1 b a . S-LW x Trea.tmE?,"It LW
b: feet
'tl-- FOR SLUDGE ACCUMULAT I Ot4
1r)1t,rre -- +f,r7 cubic fee'_. SLUDGE r=cCC'JMULFTIOt3 t�� r
AT ©WNIFFERS' REDUES-` REMOVE- Z1DGE
f.� DESIGN . aLUl; E AS NE'�!)ED .
lnside tc;p length 260.0 feet ; Inside top width 150.0 fez-!-
Top of d i .I e at elevation 52.0 feet
c ro2,~raard i.+:> feet Side Slopes . �� 1 (InsirJ� lacooF, )
Total de_;�.gn lagoon liquid level at elevation 51.o feet
Bottom of lagoon elevation 40.C) feet
Seasonal ;-sigh water table elevation 46.2 feet
Total JLysi gn volume_ using pr.asmoidEsl formula
S':!E N:) S'=/F.ND2 SS/SIDEI SS/SIDE2 LENGTH WIDTH DEPTH.
_ C) -,C) _,s_'r 2-,4,fj 144,0 11
R.'T
-_r' 1 -a '..'T TO
WIDTH70.
=
?dc?.a (.AREr1 f,E ![iF')
1 . 64 ((FREA OE BOTT0M )
�C_ T,' LJ 1 DTt'I 4
-...- L -8124 CARER OF MIDSECTION * 4 )
TOP ' - Or,FA M r -),qFC T T a!,l i r AR.E-.P FC T- F}r
3r;57f,, 1l g81,4. r7 14664.+_? _
L J: E _` = r? _ _ `:!P 1 MTAI__ DES I Srd _ 1 G U 1 D LEV+ l_ _ '177E�.'_•4 C: J . !=

S'^F-Ok,Ar.Y STOF.AGE_ C?iJIRED
0 P A i N tc', 177 E A R.r:-A
^. tii_i . _l
Llilil5 ��c =rr�'t and IG'C. wz.tl=r)
_'.C) 1.1 square `eet
TOTAL DA 39000.0 square fF-e _
Design temporary storage period to be a; s.
'.'olume of v;aste produced
Approximate daily production of manure in CF/LF SSLW 0136
Volume _ 182400 I_bs, SSLW * CF of Waste/Lb./Day ISO' days
Volume = 44652 cubit feet
iB. Volume of wash water
This is the amo?cnt of fresh water used for washing floors or vDlume
of fresh water Used for a flush system. Flush systems that. recirc_u 1 ate
,_he :-jatF�=r are accounted for in 5A.
D10 gallons/day .180 days st._r-age.'7,4� Ljall:jam?=
Cubic feet
of i ,f zll in excess of evapnrati-ir
LI;:� ❑c'-_C:C '? -_"re whet: rainfall Exce—i=ds evaporation- by
rainfall
0in * DA / 1-2 inches per foot
_ubic feet

Jnl_ime ?'r y-ear' - 24 hour- storm
VO; Unie = 7.'._> inches 1 12 ir,cher, per .fob )t_ I'N'1
C7 i. LF:r1 __ `2!5f_1,1-1 cubic fe1�t
-_QL , <<C=:) TEMPCRAF.:Y STOS:(Ii S F
� c_5 bi,- fe,e
!- cubic fec-t
2''1750 cubic feet
_=75t) z u b i c fes- t
TOT!..!_ 1?0152 cubi _ feet.
SUMMARY
Total required volume 272552 cubic feet
Total design volume avail. .273834 cubic fleet
Mir-. req. treatment volume plus sludge accumulation 18240C) cubic t
At elev. 48.1 feet ; Volume is 183547 cubic feet (end pumping?
Total design volume less 25yr--24hr storm is 251084 cubic feet
At elev. 5C$..3 feet ; Volume is, 248812 cubic feet (start pum_ping)
eas na hig~ water table elevation 45.2 feet
D4"--E: i11r� 3 11A1 C.:
N J- F : Sf_ E !=,TTACHED WPiGTE UTILIZATION FJ_AN
n

U._ S. Department of Agriculture
Soil Conservation Service
NC-ENG-34
September 1980
HAZARD CLASSIFICATION DATA SHEET FOR DAMS
LandownerT
0,1&�Fq�rtMS-
_ County .7,dmPScAj
_
Co[.munity
or Group
No.
Conservation Plan No.
Estimated
Depth of
Water to Top of Dam
Ft. Length of Flood Pool Ft.
Date of Field Hazard Investigation 2-4Z 7 Zq j _
Evaluation by reach of flood plain downstream to the point of estimated minor effect
from sudden dam failure.
Est. ETev. :Est. Elevation
Kind of :Improvements: of Breach
Reach: length: Width: Slope: Land Use Improvements Above :Floodwater Above
: Flood Plain: Flood Plain
t. Ft, t, t.
1 /Zoo
2
3
Describe potential for loss of life and damage to exi tang or probable future downstream
improvements from a sudden breach_ _ *.yg _ W,,,, -A,,,,. ,4 ,* d 4,,
Ha::ard Classification of Dam &) b, c) (see NEM-Part 520.21)
Dare Classification (I, II, III, IV, V)
By_
name
,D . C.
re-F�
ConcurredBy
name t t e
MOTE: 1. Instructions on reverse side.
2. Attach additional sheets as needed.
Date ZZ—&Z 3 -
Date

0 101
­4
T
Lj
T.P.
JJ
-0-j
4-1 ul
il(
m _4
Ill
J
0
0 tri
IV r., I
ill LR
U
0
'J
-1.] 11!
fr:"
f;
.w
0 la
tj
01
0 1
Ill
!J
PU LL 4. 4
RIt iJ
-U
ITjj 4J
(it
(4
1
k
tj
r
k.1
q f
lit
!11
4 i I_' "i
.,I
?Ti
III Ill
lif Ill
Jj
I
-ij
_TJ
lit
ip
411 1
.17
"i
.17]
j
II' f-L
1
7?
j
]-.t Ttj j I
:_I 41
LN 1
.1 fff
':I.
L
7":
-1
Lj C
II Eli
(it
(1 3
>
tr
'Ll F]
Lff
lit -I
t rl
LILT
ji'l L.
_0 11
P L.
Y.
ifi
U
F
Lit
—i
1p IIJ
J_:
_l.
r,i r,.,: r
LP
C: 4"
1
If1 kI.T
c.
V
I
4_1
.1.4
4-1
t I L
4 1,) A
li RI
kri
L I
in
Ij 111
11
W
I_
C
L.
X.1 1 1
.4 -,1
f 61
7-i
f-I
'JI
17 U'
•U
Tj
r 1 V
4J
I -rl
A
Ili M
1,-. 4-1
IV
>
I
_fJ
ill I') V
Lt ]t
U 111
111 ­4
I(Ij
U.i p J. , I
{)I r-
ill
rl
R1
L
0
C
i —t
T. i
;Q
L:
Ij 9, 1
u 1
-1
1 -r I
I" 1 4
k.. -,i
I r;
'i I. -I
P-
I.J. Ili
I,! !Ti I.I.
j
j
Lit
L.
Lb
0
1 '-
-1 '11 ai-
ut
'Zi
Ili
CI.
Lt
i I Q, U
ki
q 1
7 if] Ili Cl
0 r
L
c .,-:
- ,
Ri
c
!,,ri
1... 4_1
III r, it Et!
-'-! '
ill
-V
In
[i !0
I.Fl J-1
4-
Ij li,
k
!:,. r-I qj
c 111
;-J
ip Ln
I I* f
, ii - -
E-
I -I!
'I
J
Tl
1 j
I
I I
iri I.J
rp
1. '1
ID
' 'it
L_
I.A.
it; •-1
'�j EI,
•r_�
I'Ll
>
Ih
C
11, 1 '1 4-
'T7
J
I.A. Lit 4-'
L
krl
LI)
CU 'Lt
-C In
ti
J J­
41 J. -4 ­1
4J
;,I I!
#J 11 4- 1 1- .1.1
Ij, L
0 L_ LP
I 1; 0 t
L9J T ", ITi 4-1
c Li,l
I I,
T-i rl I­
fri
-1
".7
4_1
P
If!
U
CI IfI
!.II
QI Ifi
LIU 0 1+- - u"t
IT; L1 IJ
j;; > _I14.4J
JD Ir
> j r-j U1
J, I A--
I
Q,
P
In -I
-j
L (fl I,R QI
ill ITi
Ili
1.9 th
rl L i it
IP
I IJ -.--I
EllLl
C, Q' C-L
T.Il
'I;
4
ID 4-1
Li ­1
1 1
9
j: III
41 1.-1 j j--!
I ij I_!
(.Fi IT 1":
'Cl
4 J F-. 11 JJ
r-1
1L-7 i11
4
lil
Cp 11.1
'1-
0, !'„;R
loll !.rl
ti rT
4-1
X" c
Li! CL
Iii
�JJ C 4-1 fl.
+
ri
u 4-1
L f11 Lfl
i__
j:j. J-1 L=
r-
I Yl
U >
to 0
rri
4,1 111
Ill
Ill 4-1
ID L
f--1
I Ili
I'rj U
qj Lt.
7 'TJ rO
4-!
L"'im .0
% .
0 - I It;
Q
'Li
L. I
.,A L c
>, --� 1
4.1
D Ctl
4j P
U 0 4-T
U - !J
TP
Z: V 111 4-1 ill
ull ID T)
In
Q1
EI Ili ij, I'l I (i
Ij i 'I-'
C_
'U L-1 Ill 1-3
Ti c
I[i
!1.
U 1-1, C rJ1
L Ili
rt! .,I 1
0 Ill
Ili
lii
rll Ili Ili
4. .,Y,: j CL f - Ln
J. !J1
ill f
Lrl
to
ill
-4 C
4 OU, 1 11 Lh L.1
_C'
L.
I q-
7� >.
ra
G.
7-:
IA !1: Ill ijl f"i
.4 j trl
cr
1': 1-
1.1
C K!
CI !11
L
L
rr
Ll.
-Lt
10
,
;It
CII 4
U
!Ti 1.11
f!j
19
ITi CI
p
11 J,
V 1J

Gl
T!
­T Ifl
4j
;� Ill
Ii- lit C
ITi
fTi
Ill lit
A. I
U [A
It:
T I
ij I
1 4
J:
ITI
I-P
at -, I
Ili 14-
L L
ij
cl
Ill JL1
SJ trf
F_
'Ti
jr
jJ 1 D Q
Q
4-!
L IP
to
kit
-1, Ti 1p _t. I
�i 3
13 dt ill rl
rz
(11
ILI 4.1
f[
J]
U
4. 1 ITi lit
1Y. W I
ro at
(it 4
4.1
0.1 01
J r(i
1 01 Iti
Ili
Ili 4.1 M
r X ill
311
T
.!t7
U
1-1 4 1
I.III
U I
u Ill o I'l t
L11 -1
T' S. rti
fit
CI
I IJ
Cl c
Cl` 0
"CI
At Ilr
AJ it:
L.
x.
III fill
cj4 -L:l
LI
Ill
k.
.,-I rl CI
JIT ffi
n aj
.,-!
ji JL)-
171.. UU
-I I
C1 4-' I':.! Ili
n.
Ili Ir,
-
Cl .1 -! f(i U
! F -- 7
T
Ll.
!1
flj -'i L
U� ITj c
.C: -q I :L
411 C ',4
(D
4-1
lit 1.111 pi
1- 4 1.1
[.! fO
OJ
',:: I.Ii j ] -[i
I;__ -j t., fft
•[fl
aI
j-I
C C
0
ffi la
ill
r.
-I.
4
Lt.!

Microbac Laboratories, Inc.
FAYETTEVILLE DIVISION
817 CASTLE F3AYNE STREET
FAYETTEVILLE, NC 28303
[phone] / [phone] (FAX)
AIR • FUEL WATER • FOOD
CERTIFICATE OF ANALYSIS
CLIENT: NC DEHNR
ADDRESS: Wachovia Building, Suite 714
Fayetteville, NC 28301
CONTACT PERSON: Mr. Jeffery Brawn
ACCOUNT NUMBER: #KN003
SAMPLE ID: 1. Lagoon Dike Bottom - ID #99WE31980
2. Downstream - ID #99WD31981
3. Auger Hole - ID #99WE31982
4.
NC #11
NC #37714
USDA #3787
• WASTES
CERT #26009
DATE REC'D: 03/22/99 SAMPLED: 03/22/99
SAMPLED BY: J. Brown
DELIVERED BY: J. Brcrm
SAMPLE CODE: Waste water, Grab
REFERENCE: Carr Farm RECEIVED
NIAR 2 6 1999
FAYETTEVILLE
REG. OFFICE
DATA REVIEWED BY: Alw- -.+.r
DATE .REPORTED: 03/25/99
ANALYSIS b071 D 1 2 3 4
COLIFORM, FECAL (per 100 ml)
SM18 9222D
9
<9
<9
NITRATE (mg/L)
EPA 353.2D
<1.0
1.42
82.2
NITROGEN, AMMONIA (mg/L)
EPA 350.2
42.72
130.05
88.87
COUNTS: < = Less than
> = Greater than
PAGE 1 OF 1
The data and other Informedon contained on this, and Mar accompanying documents, represent only the samples) analyzed and is MEMBER
rendered upon the conditkon that it is not to be reproduced wholly or In pert for advertising or other purposes without written approval
from the laboratory.
USDA-EPA-NIOSH Testing Food Sanitation Cansullfing Chemical and Microbiological Analyses and Research

0
Microbac Laboratories, Inc.
FAYETTEVILLE DIVISION tic #11
811 CASTLE HAYNE STREET 9C #317.14
FAYETTEVILLE, 1 C 28303 USDA #378 7
[phone] / [phone] (FAX)
AIR FUEL WATER FOOD * WASTES
CERTIFICATE OF ANALYSIS CERT #26009
W OTARNT: KC T]99NR
DATE RRCnD: 03/22/99 SAMPLED: 03/22/99
ADDRESS: wachovia Bui.ldinq;o Suite 714
SAMPL'ED BY: J. Brown
Fayetteville, NC 28301
DELIVERED BY: JJBrown
i; NTACT PERSON: Mr. Jeffery Bry.NT,
SA14PLE CODE: Waste water, Grab .
v ` '
`R1 'Casr+ 'arm
rgCC.t?Li1:T NiSt�1LER: #E1CtjOG`3
F'EFE[dC :
SPI,IPLE ID: 1. Lagoon Dike Bottom - ID #99WE31980
2. Dcrm3tream - 117 999WD31981
1>
3. Amger Hole - ID #99WE31982
9
:
DATA. REVIEWED BY:,uz,,__-• ._
0/25i9A
DAT1 RFPC)RTE D:
1 4r#++:
il+#s+++++++#i+i:i+4. 4-1 +A4i+i+++++;.44-
ANALYSTS ;'� METHOD
1 2 3 a
COLIFORM, FECAL (per 101) ml.j SM18 9222D
g � ` <9 <9 .s
NrTRATF (mg/T,) EPA 353.2D
<1..0 1.42 02.2
NITROGEN, AMPlONIA (mq/L) EPA 350.2
42.72 130.05 88.87
ijf
1Vbffl4TS • ♦ Le i s than
f�
�(
> Greater than
PACE 1 OF 1
` The data and other Irdorrrration cordWried on this, end other accompanying d=merrts, mWeserrt only the samples} anefyzW and is
MEMBER
rendered upon the condplon that it Is not to be reproduced whooy or in part far advertising or other purposes without written approval
nd
from the Isboratory-
USDA-EPA-NIOSH Testing Food Sanitation Consulting Chemical and Mkmkiological Analyses and Research

NCDA Agronomic Division 4300 Reedy Creek Road Raleigh, NC 27607-6465 [phone]
Report No: S01064 S
Grower. Carr, Jim
Copies To: County Ext. Dir. -Sampson
y, ,
642 Enoch Rd.
rr, f:
:..,•�l,.f�
Solution
Clinton, NC 28328
o
x:a. Analysis
...�
R e ort
-.
�` Farm:
3/19/99
Sampson Count
Sample Information Laboratory Results
arts per million except for EC, pH, SAR, and where otherwise noted
Sample ID:
N
P
K Ca __Mfl S Fe Mn Zn
CU B Mo Cl Na
Total
124
73.0 5.94 7,22 3.82 6.93 0,04 0.01
0,00 0,03 56.3 25.7
OHC1
IN-N 106
Solution Code:
-NH4 102
QS
-NO3 3.82
Ni
Cd Pb Al ti Se FC pH
SAR TotalAlkaiiniry Hardness
Description:
OR-N
97 630
1.7 290 44
Surface Water
Urea 0.15
Recommendations:
Ammonium nitrogen and potassium are significantly higher than normally found in good quality surface water, This may indicate an impact on the environment in this area. I would try to determine the source of the
nutrients and ei iminate them from the water supply,
C. Ray Campbell, Agronomist
Sample Information
Laboratory Results its
per million except for EC, pH,
SAR, and where otherwise noted
Sample ID:
N
P
K Ca Y9
S Fe Mn Zn
CU B MO Cl Na
OHC2
Solution code:
QS
Description:
Surface Water
Total
IMN 118
-NH4 115
-NO3 2,78
OR-N
Urea 0.67
000
111 773 857
6,75 1.61 0.03 0.00
0,00 0.06 79.9 35.9
Ni Cd Pb At Li Se EC pH
SAR TotalAlkafinity Hardness
139 7.02
2.1 585 54

r
H
Cl,,,., - o�-, s,�

r_
1 =
JAMES 13. HUNTJR.,- t
GOVERNOR
r.
WAYNE MCDEvrrr. ' .
SECRETARY
' NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
FAYETTEVILLE REGIONAL OFFICE
FAX COVER SHEET
FAYETTEVILLE REGIONAL OFFICE
DATE: -7121.1 �F y
TO: 61,4� 67111v-0
FAX #: (%1o) C�2 - FS- S2
FROM: 13a4 AAILI
Number of pages, including cover:
NOTE:
225 GREEN STREET, SUITE 714, FAYETTEVILLE, NORTH CAROLINA 28301-5043
PHONE [phone] FAX PID-486-0707
AN EQUAL OPPORTUNITY /AFFIRMATIVE ACTION EMPLOYEII - 50% RECYCLED/10% POST -CONSUMER PAPER

FAYETTEVILLE DMSION
817 Castle Hayne Strut Fayetteville. NC 28303 Phone [phone] Fax [phone]
CHAIN OF CUSTODY RECORD
PAGE OF
ENT tom; ADORES&
VC jrn/ R — D GJ
Sr,
�)Wwt A/c_ & T—V o (
Po /
OJECT r LOCAT M.
(f err rq.
a OF
0
T
T
L
a
a
TYPE
OF ANALYSIS
PRESERVATION CODE
�,ll
tiL
• t
CODE: A - WC ONLY
B a HNO3 (phe4 + -WC.
C = H2SO4 6*W4 + -WC
D - NaOH + 4CC
E - zN Acdde + -WC
F -
ACT PM3M:
1/0 - q1? 6 - 1SSV /
tfpLErR D
�a6 Gar
DATE r ME+lr►m of a+u namr.
LAB ID #
SAMPLE TYPE
DATE
TIME
COUP
aR,B
pt
DrD
�
3 -a-2- 9 9
a: 0
✓
3
la o✓%r� �: Bo
3 17 r cj jam'
o�
'�
97
.2.' /-5
npuhmed W. (i re)
P.
Data
-aarq�
Time
3;55-
Recahed W. (Signature)
Dan
3az-
Time
3;
nature)
Dana
a
Racatwd W. (Signature)
Duty
Time
3
4
W. 134neft y1
Time
Received W. I3gnaa+n)
Onto
TIme
5
6
WW 21 W. (34neture)
Data
Received W. (Signature)
Dan
Tin
7
[Me
8
Cornnwts or Special Hazards:

RUDCAR FARMS, INC.
P. 0. BOX 857
CLINTON, NORTH CAROLINA
September 21, 1999
Mr. Jeffrey Brown
Environmental Engineer
NCDENR
225 Green Street
Suite 714
Fayetteville, N. C. 28301-5043
Dear Mr. Brown:
RECEIVED
4E P 2 3 1(M
28329 FAYE rTEV1LLE
REC. OFFICE
RE: Rudcar Farms, Inc.
Facility No. 82-35
Lagoon Seepage
In response to your letter of July 28, 1999, 1 have the following to report.
As you know, when we first suspected any seepage from our lagoon, we immediately
took appropriate water- samples as directed by Mr. Glenn Clifton of Prestage Farms.
As soon as the results of the samples were received by us we notified DWQ Water
Quality and Ground Water Section in Raleigh immediately (the same day) and
requested an immediate visit to our facility by you and your staff, which you did
the next working day.
We are totally committed to safeguarding the environment, insuring the integrity
of our lagoon, and protecting our hog farm.
We have engaged the services of a professional engineer, Mr. M. Floyd Adams, P.E.
of the Adams Company, Kenansville, N. C. to evaluate our lagoon and the seepage
problem and also to advise us with a plan of action to correct the problem as
soon as possible. Enclosed is a copy of his report to you that I assume you
have received.
In his letter to you he advised that he is still collecting data, estimating costs,
and evaluating alternatives. He hopes to provide you with more details as to our
final plans within 30 days. He plans to meet with Mr. Wilson Spencer and personnel
from your staff, NRCS and soil and water on September 22, 1999. He hopes the results
of that meeting will help in the decision making process. Enclosed are copies of
the water and soil samples taken by Mr. Adams on his site visit and evalution of
our lagoon and farm.

I hope that the above information and schedule regarding determining a final
plan of action is satisfactory with you. If not, please advise us as soon
as possible.
We are anxious to protect the environment, insure the integrity of our lagoon
and keep our hog farm in total compliance with state regulations. We appreciate
your cooperation and look forward to working with you to correct any problems.
Sincerely yours,
Jim Carr
Managing Partner
Rudcar Farms, Inc.
JC : j sm
cc: Mr. Glenn Clifton
Prestage Farms
P. 0. Box 438
Clinton, N. C. 28329
Mr. M. Floyd Adams, P.E.
The Adams Company, Inc.
P. 0. Box 1098
Kenansville, N. C. 28349

RECEIVEDADAMS COMPANYINC.
CONSTRUCTION AND DEVELOPMENT
132 Routledge Road, Post Office Box 1098
2
` Kenansville, North Carolina 28349
FAYErmyiLLE Phone/Fax [phone]
Ems_ RF1e= -
(Engineering provided by The ADAMS COMPANY, htc. through a partnership agreement with M. Floyd Adams, P. E. )
September 15, 1999
Mr Jeffrey Brown
Environmental En,ineer
hCDENR
225 Green Street
Suite 714
Fayetteville. NC 28301-5043
Subject: Rudcar Farms, Inc.
Facility No. 82-35
Lagoon Seepage
Dear Mr. Brown:
Please be advised that Mr. Jim Carr has secured my services to assist him with revic%%'
of the lagoon structure at Facility No. 82-35. To date we have performed a general evaluation
of the dike structure and completed several soil borings to determine the composition of the
dire as well as the surrounding natural ground.
From you letter dated July 28"', I feel. -the number one issue for me to address is the
structural integrity of the dike. Based on my inspection, the soil borings, the height of the
dike, the water table and other visual characteristics, it is my opinion that this bike structure is
safe and it does not pose a threat to the environment.
The other issues regarding surface water and ground water are also very important,
however, they require more review and evaluation. We are still collecting data, estimating
costs and evaluating alternatives. We hope to provide you with more details as to our final
plans within the next 30 days. I will be meeting with Mr. Wilson Spencer and personnel from
vour staff, NRCS and Soil & Water on September 22'. I believe the results of this meeting
will help in our decision making process.

If this schedule does not meet your approval, please advise. We look forward to
working with you to resolve all concerns.
Sincerely,
M. Floyd"/Adams, P.E.
MFAlthj
cc: Mr. Jim Carr
Mr. Glenn Clifton
Mr. Wilson Spencer

NC�gronomic Division 4300 Reedy Creek Rd Raleigh, NC 27607-6465
[phone]
r;
L 4
ton d='t Understanding the solution AnaiysisRe-hort
Water quality is important to all North Carolina citizens. Everyone has the responsibility to help maintain our water supplies. A mineral analysis provides information on the
quality of surface or ground water as well as nutrient solutions. This information) is vital to the success of agricultural production systems including crop,
livestock, and poultry
production; aquaculture; and pond management. A mineral analysis also provides a means for monitoring general water quality and protecting the
environment.
Sample info This section contains sample identifier, specificaliy the sample identificalion number, solution code, and a description of the intended
Key to Abbreviations
use of the solution. These data are supplied by the grower oil the information sheet subillilled vVith each Sample. 'rile soltlliorl use code given on Ilic
information sheet affccls interpretation of the analviical results.
Ai
Aluminum
AR
Acid requirement
Laboratory Results Determinalions of elements are reported in parts per million (ppm). Essential elements include lhose required for normal plant
B
Boron
and animal growth —major nulricnlS (N, p, K), Secondary nutrients (Ca, Mg, S), and micronutrienis (Fe, kin, Zn, Cu, 13, hlo, CI). Concentrations of
Ca
Calcium
potentially harmful elements (AI, Cd, Li, Na, Ni, ph, Sc) are also determined, depending on (lie Ivpe of sample and its intended use. Values arc
Cd
Cadmium
intcrprcle(l .cti V1. (very low), t. (low), NI (medium), 11 (high), or V1I (ven high) based on the type of ►Hater and its intended use. Except for nutrient
Cl
Chlorine
solutions, values ranked as 1, or Vl. are desirabie.
Cu
Copper
Electrical conductivity (EC) is reported in unitS of nlho x 10-5/cn12. II measures the combined amount of dissolved solids or minerals in water—
EC
Electrical conductivity
primarily N, li, Ca. ,Mg, Na, Cl, and 11CO, It is an indicator of the level of management required to successfully use the solution.
Fe
IN-N
Iron
Inorganic nitrogen
The sodium adsorption ratio (SAR) indicates the degree of balance among Ca, Mg, and Nit, 11 is uSeful in predicting the tendency for Na to accumulate
IC
potassium
in soil where the wafer is routinely used for irrigation. Wbere overhead irrigation is used, toxic levels of,.Na can accumulate On the foliage. Since SAR is
Li
Lithium
a ratio, it has no unils.
Mg
Magnesium
Total alkalini1v is the sum of carbonate and bicarbonate ions reported in ppm. Most alk:llinily is in lllc bicarbonate form. This value indicates file
Mn
Manganese
tendencv of +v.ater to increase soil pi where irrigation is routinely used. In some plant production systems, alkalinity must be neutralized to avoid
Mo
Mol)i)denum
increasing soil pl I Io levels that do not support plant growth.
N
Nitrogen
Hardness indicates the amount ol' calcium and inagnesillln in water, expressed :as equivalent calcium carbonate in ppm. It is usclid in cv:dualing
Nih-N
Ammonium nitrogen
water quality for agaaacullurc and domestic uses.
NO3-N
Nitrate nitrogen
The acid requirement (AR) value indicates the number of ounces of hancry acid (9.19N sulfuric acid) 10 apply to each 100 gallons of %%.filer to lower
Ni
Ni
Nickel
Nickel
Ilse pil to a desirable level. The AR is calculaled to nculralize H(l% of the alkalinity.
OR-N
Organic nitrogen
Nitrate nitrogen (NO -N) and aninioniurn nitrogen (Nil -N) are prinian, indicalor of %valer qualliv. High concentrations of These nutrients may
p
Phosphorus
indicate a wall corlslnlrlion problem or an environmental inlp:n•I in Ille vicinity of the wider supply. Nitrate and ammotlrllrn nitrogen are Treasured for
Pb
Lead
:all sur'i.0 e and ground water saralplcs. I IIgIa cUllCf IllrlllU115 111 IbCtie 1nIInCnIS Inav rcq(lire follow-up sampling to confirm the status of the +v.uer supph'-
pll
Measure o€icidify/alkalinity
AI(r_sl plants have a high Tolerance liar nilrale and ammonium nitrogen and ulilizc Ihesc t+n•nls cfficienlly. The recorrirnended upper lirnil of ilitrale
on ascale of I to 14
nilrogell for honiall constimptioll is Ill pprrl. iNIOSI surfa('c.md ground water in North Carolina contains under 3 ppin nilr:atc nitrogen.
S
Sulfur
SAR
Sodium adsorption ratio
Recommendations This seclion provides an inicrprelalion of results along with suggcsled managcnlcill strategy. For• diagnoslic samples, sile-specific
Se
Selenium
rccolnnundill ions arc given h;iscd on Ill(, description of IIle prol}IcrTl provided ell (tic Itrlifr'lllall[lll sheet.
7,n
Zinc
) ,ei 10,100 copirs u! [tlis pis hlit. fluru 1114-111 ware printed a! d cost or SLn 1.'?','' or S(I.O_ per f 411)Y.

F. ,
i,Ml
.,'"Y­ '-�
cbivisio�66
Road 6��432 i�lkl
eCYCrek ..
Grower Rijdcar Farms Itic. Copies lb. Presiage F,,ircms Inc.
Altwjiin Carr Comity Ext. Nr. - SaMI .......
110 Box 8S7
Clinton, Ni, 283 28
-
EC�
,j,LA. OlutionAnalysis effort
•
9/14/99 Sampson Comity
Sass W InforcnaUan'.k,', 1? I.Aiiriatoriy`.Results"(parts
kr milfi6n eicept for'EC'�
Sample ID.-
N
P K Ca h!g S re M11 7n C" R Mo Cl Na
Total
Lot 29.2 3.06 2.14 4.08 0.10 ON 0.00 0.00 0,07 75.2 27.1
IN-N 53.4
Solution Code:
-NH4 28.4
Ni Cd Pb Al Li Se FC pl/ SAR TutalAlkalinity Hardness
QG
NO3 25.0
Description:
OR-N
54 4.77 2.9 20 16
Ground Water
Urea 0.79
Reco TV A i " �Aj.lil VENIKk
I , , ` 4
j, 61, "T
�Ii 1�� * I , " ,
4, �6
A V i ". . . �, I., - N
'��thk& ".t
-
Wo,f,&e simite��Ui��10i p16 kfdre'i�W&.-Wtrqgen iffVOUW6m sig ic 11y,,•
G6W.Wnfih A' ,
g-nificantarnounts'of i6*,ncied'soli&',?4Wt,flitLIKA.L UILS I
U Itylgg,
v g,4 ori't . H
A�&r tt i-Y U1 samp, es�� And'Ti AlUihit --also"i&Y MOTin S�-rfiple-Yjh6e res'Wts-� maY indicale a we 'constniction,problem-in&or anjin the 'th.is �iW,146ulfilkl-�'AA
eyeA�Z high "1 '2" environment in
y
the�sobrce'of the,flutn i pleY.'s to O'n,firm, the findine aj1d'tr-(O`&t` nutrients I M �A
y X.
IfIn'.10W, V-, 'K. g jr TV o4
M M
d. , , v, 1A,
law, R ki �,K 4111- %11, R , I I
�w Vi
R�f 11, A k 6 n o r i 1 t
'Wfijob�
S FjhfrrKifl� VAIftWUIWfWt6IrIyIAReIsI6
IMNIVI WA MeAT7
Sample ID.-
N
P
K Ca
Mg
S Fe Mn
zn
CU
B Mo Cl Na
i�V
Total
2.33
347 15.4
16.9
7.27 16.4 0.11
0.01
0,01
0.30 270 86.2
IN-N 382
Solution Code:
-NI14 380
Ni
Cd Pb
At
U Se EC
pit
SAR
Total Alkalinity Hardness
QG
-NO3 2.05
388
6.79
3.6
20 108
Description,
OR-N
Ground Water
Urea 2.93
milfiirfexceOt for
Sample ID.,
N
P
K Ca M S Fe AM
71,
Cu
B Mo Cl Na
v ggg
Total
0.9g
167 11.0 11.5 11.8 0.24 0.03
0.00
0.01
0.15 137 52.9
IN-N 194
Solution Code:
Alh/ 192
Ni
Cd Pb it/ Li Se EG
PH
SAR
Total Alkahniq, Hardness
QS
-NO3 1.78
229
6.60
2.7
1970 75
Description:
OR-N
LStAtmeWatcr
Urea 0.34

THE ""S COMPAIM INC.
CONSTRUCTION AND DEVELOPMENT
132 Routledge Road, Post Office Box 1098
Kenansville, North Carolina 28349
Phone / Fax [phone]
(Engineering provided by The ADAMS COMPANY, Inc. through a partnership agreement with M. Floyd Adams, P.E.)
September 15, 1999
Mr. Jeffrey Brown
Environmental Engineer
NCDENR
225 Green Street
Suite 714
Fayetteville, NC 28301-5043
Subject: Rudcar Farms, Inc.
Facility No. 82-35
Lagoon Seepage
Dear Mr. Brown:
1 T1999
Please be advised that Mr. Jim Carr has secured my services to assist him with review
of the lagoon structure at Facility No. 82-35. To date we have performed a general evaluation
of the dike structure and completed several soil borings to determine the composition of the
dike as well as the surrounding natural ground.
From you letter dated July 28', I feel the number one issue for me to address is the
structural integrity of the dike. Based on my inspection, the soil borings, the height of the
dike, the water table and other visual characteristics. it is my opinion that this dike structure is
safe and it does not pose a threat to the environment.
The other issues regarding surface water and ground water are also very important,
however, they require more review and evaluation. We are still collecting data, estimating
costs and evaluating alternatives. We hope to provide you with more details as to our final
plans within the next 30 days. I will be meeting with Mr. Wilson Spencer and personnel from
your staff, NRCS and Soil & Water on September 22'. I believe the results of this meeting
will help in our decision making process.

If this schedule does not meet your approval, please advise. We look forward to
working with you to resolve all concerns.
Sincerely,
141
. -A3� 4��
M. Floy Adams, P.E.
MFAlthj
cc: Mr. Jim Carr
Mr. Glenn Clifton
Mr. Wilson Spencer

THE AD"S COMPANY INC.
CONSTRUCTION AND DEVELOPMENT
132 Routledge Road, Post Office Box 1098
Kenansville, North Carolina 28349
Phone/ Fax [phone]
D
November 18, 1999
Mr. Jeffrey Brown
Environmental Engineer
NCDENR
225 Green Street
Suite 714
Fayetteville, NC 28301-5043
Subject: Rudcar Faris, Inc.
Facility No. 82-35
Lagoon Seepage
Dear Mr. Brown:
NOV 2 3 19"
FAYETTEVILLE
REG. OFFICE
I have been in contact with Mr. Jim Carr on several occasions since my letter of
September 15°i. He is interested in making the corrections to this farm as soon as he can
gather all pertinent information related to this matter. We feel the meeting that was scheduled
for September 22nd was to be very important in determining our final plans for resolution of
the problem. As you know, Hurricane Floyd prevented this meeting from occurring.
We are most interested in rescheduling the meeting with Mr. Wilson Spencer, his staff,
your staff, NRCS and others who share an interest. I believe the meeting could provide
beneficial information to all parties involved and help everyone develop ideas and methods to
resolve problems similar to Mr. Carr's. By copy of this letter to Mr. Spencer, I would hope
that your office and his office could establish another time for this meeting.
On behalf of Mr. Carr, I request that he be allowed time for this meeting to take place
t' .-. to s—nissi�- f his f., al plans for resol�:tion of the scepage. Should we need to act on
this matter sooner, please contact me at 910-296-1170.
Thank you for your assistance in rescheduling this meeting and allowing Mr. Carr the
necessary time to review his situation after the meeting.
Sincerely,
7. T
M. Floyd Adams, P.E.
MFA/thj
cc: Mr. Jim Carr
Mr. Wilson Spencer
Mr. Glenn Clifton

DENR-FRO
Fljo 1 12013
CCDENR
North Carolina Department of Environment and Natural ReSourceE
Par McCrory
Governor
Carr Boy Farms, Inc.
Carr Boy Farms, Inc. 5-8
201 Tomahawk Trail
Clinton, NC 28328
Dear Carr Boy Farms, Inc.:
Division of Water Quality
Chaves Wakild, P.E.
Director
February 6, 2013
Dwo
.John E. Skvada, Ill
Secretary
Subject: Certificate of Coverage No. AWS820035
Carr Boy Farms, Inc. 5-8
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
In accordance with your February 6, 2013 Notification of Change of Ownership, we are hereby
forwarding to you this Certificate of Coverage (COC) issued to Carr Boy Farms, Inc., authorizing the
operation of the subject animal waste management system in accordance with General Permit
A WG 100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for the Carr Boy Farms, Inc., 5-8 Farm located in Sampson County, with a swine animal
capacity of no greater than the following annual averages:
Wean to Finish: Feeder to Finish: Boar/Stud:
Wean to Feeder: 6080 Farrow to Wean: Gilts:
Farrow to Finish: Farrow to Feeder: Other:
If this is a Farrow to Wean or Farrow to Feeder operation, there may be one boar for each 15 sows. Where
boars are unnecessary, they may be replaced by an equivalent number of sows. Any of the sows may be
replaced by gilts at a rate of 4 gilts for every 3 sows.
The COC shall be effective from the date of issuance until September 30, 2014, and shall hereby void
Certificate of Coverage Number AWS820035 dated October 1, 2009. Pursuant to this COC, you are
authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Please pa careful attention to the
record keeping and monitoring conditions in this permit. Record keeping forms are unchanged with this
General Permit. Please continue to use the same record keeping forms.
1636 Mail Service Center, Raleigh, North Carolina 27699-1636
Location: 512 N. Salisbury St. Raleigh, North Carolina 27604
Phone: [phone] FAX: [phone]
Internet: www.ncwatemuality.org
one
NCarolina
aturallrf
An Equal opportunity 1 Affirmative Action Employer

If your Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Per 15A NCAC 2T .0105(h) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100-foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be. advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, then an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Unit for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition 11.22 of the General Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Tropical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You
may find detailed watch/warning information for your county by calling the Raleigh, NC National
Weather Service office at [phone], or by visiting their website at: www.erh.noaa.gov/er/rah/
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Aquifer Protection Staff may be reached at [phone]. If you need additional information
concerning this COC or the General Permit, please contact the Animal Feeding Operations Unit staff at
[phone].
Sincerely,
for Charles Wakild, P.E.
Enclosure (General Permit AWG100000)
cc: (Certificate of Coverage only for all ccs)
Fayetteville Regional Office, Aquifer Protection Section
Sampson County Health Department
Sampson County Soil and Water Conservation District
APS Central Files (Permit No. AWS820035)
AFO Notebooks
Prestage Farms Inc

ANIMAL WASTE UTILIZATION PLAN
Producer: RKERIED RMfAR FARMS INC.
Location: P. . BOX 857
R 1 CL NTON NC 28441
Te l ephone _DENR-FAYri�MUE RFOONAI 5 64 - 6 7 6 5 ,: _ lrv16'k 1
Type Operation: Existing W to Feeder Swine
Number of Animals: 640Y8-6 . 0 0 pigs
(Design Capacity) 60SO- On GC 4A0199
STORAGE STRUCTURE: Anaerobic Waste Treatment Lagoon
APPLICATION METHOD: Irrigation 4!5.61_ZIJ
NC!-i FIVl"I
g/ 3 a � 9 g �(. �fPa.-.� Gee( Pn<s�. •
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops
in the fields where the waste is to be applied.
'his waste utilization plan uses nitrogen as the limiting nutrient.
,daste should be analyzed before each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
I- Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply
more nitrogen than the crop can utilize.
2. soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall be applied to land eroding at less than
5 tons per acre per year. Waste may be applied -to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on saturated soils, when it is raining,
or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed
under DWQ regulations.
RECEIVED ! DENR I DWQ
AQUIFFP'PPf 7r.TinN SF(;TION
Page: I

ANIMAL WASTE UTILIZATION PLAN
5. Wind conditions should also be considered to avoid drift and
downwind odor problems.
6. To maximize the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more than 30
days prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. if
you choose to change methods in the future, you need to revise this
plan. Nutrient levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should'be based on the waste analysis report from your
waste. management facility. In some cases you may want to have plant
analysis made, which could allow additional waste to be applied.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
This waste utilization plan, if carried out, meets the requirements
for compliance with 15A NCAC 2H .0217 adopted by the Environmental
Management Commission.
AMO OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
GC4lio 99 (x R 443001
I!aif y�►+�9 s Z432 y/3n�� 9
6080 pigs x .40 tons waste/pigs/year = an
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
GC 413019 s GG 4I30197 V.
6080 pis syx .48 lbs PAN/pigs/year = 2- r==-1:F lbs. PAN/year
Applying the above amount of waste is a big job. You should plan
time and have appropriate equipment to apply the waste in a timely
manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
Page: 2

ANIMAL WASTE UTILIZATION PLAN
TABLE 1: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LES
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
-------
APPLY
RESID.
APPLIC
METH
N
TIME
2776
11
WaB
BP
4.1
205
0
13
2665
I
MAR-OCT
2776 I-11
END
SG 1
I
I
50 IO 113 1650
SEP-MAY
TOTAL13315
- Indicates that this field is being overseeded (i.e.
interplanted) or winter annuals follow summer annuals.
NOTE: The applicator is cautioned that P and K may be over applied
while meeting the N requirements. In the future, regulations
may require farmers in some parts of North Carolina to have a
nutrient management plan that addresses all nutrients. This
plan only addresses nitrogen.
Page: 3

ANIMAL WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
See required specification 2.)
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
--------
APPLY
RESID.
APPLIC
METH
N
TIME
END
TOTAL10
Indicates that this field is being overseeded (i.e. interplanted) or
winter annuals follow summer annuals.
In interplanted fields (i.e. small grain, etc, interseeded
in bermudagrass), forage must be removed through grazing,
hay and/or silage. Where grazing, plants should be grazed
when they reach a height of six to nine inches. Cattle
should be removed when plants are grazed to a height of four
inches. In fields where small grain, etc, is to be removed
for hay or silage, care should be exercised not to let small
grain to reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too
high and this will definitely interfere with stand of
bermudagrass. This loss of stand will result in reduced
yields and less nitrogen being utilized. Rather than
cutting small grain for hay or silage just before heading as
is the normal situation, you are encouraged to cut the small
grain earlier. You may want to consider harvesting hay or
silage two to three times during the season, depending on
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late
September or early October. Drilling is recommended over
broadcasting. Sermudagrass should be grazed or mowed to a
height of about two inches before drilling for best results.
Page: 4

ANIMAL WASTE UTILIZATION PLAN
** Acreage figures may exceed total acreage in fields due to
overseeding.
* lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables I and 2 above:
CROP CODE
CROP
UNITS
PER UNIT
50
50
BP
SG
HYBRID BERMUDAGRASS-PASTURE
SMALL GRAIN OVERSEEDED
TONS
AC
TABLE 1
TABLE 2
TOTAL
**
TOTALS FROM TABLES 1 AND 2
ACRES
LBS AW N USED
13
3315
0
0
13
3315
* BALANCE
GG a13'l9�
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.
Page: 5

ANIMAL WASTE ZTTILIZATION PLAN
*** This number must be less than or equal to 0 in order to fully
utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffers, filter strips along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than
the acres shown in the tables.
See attached map showing the fields to be used for the utilization of
animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient
rich and will require precautionary measures to prevent over application
of nutrients or other elements. Your production facility will produce
approximately 462.536 pounds of plant available nitrogen per year in the
fudge.
3f you remove the sludge every 5 years, you will have approximately 2312.68
pounds of PAN to utilize. Assuming you apply this PAN to hybrid
bermudagrass hayland at the rate of 300 pounds of nitrogen per acre, you
will need 7.70893333333 acres of land. If you apply the sludge to corn at
the rate of 125 pounds of nitrogen per acre, you will need 18.50144 acres
of land. Please be aware that these are only estimates of the PAN and
land needed. Actual requirements could vary by 25a depending on your
sludge waste analysis, soil types, realistic yields, and application
methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the
soil at the time of irrigation such that runoff or ponding occurs. This
rate is limited by initial soil moisture content, soil structure, soil
texture, water droplet size, and organic solids. The application amount
should not exceed the available water holding capacity of the soil at the
time of irrigation nor should the plant available nitrogen applied exceed
the nitrogen needs of the crop.
Tf surface irrigation is the method of land application for this plan,
. is the responsibility of the producer and irrigation designer to ensure
.iat an irrigation system is installed to properly irrigate the acres
shown in Tables 1 and 2. Failure to apply the recommended rates and
Page: 6

ANIMAL WASTE UTILIZATION PLAN
amounts of nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application
rates and amounts.
Tract
l Field
2776 111
I
2776
--11
Application RatelApplic. Amount
Soil Type I Crop I (in/hr) I (inches)
WaB
BP I 0.60
SG
*0.96
*
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations, the application amount shown cannot
be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions_
Your facility is designed for 180.00 days of temporary storage and
the temporary storage must be removed on the average of once every
6.00 months. In no instance should the volume of the waste be stored
in your structure be within the 25 year 24 hour storm storage or one
foot of freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply the
correct rates to the acres shown in Tables 1 and 2. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may
make this plan invalid.
Call your technical specialist after you receive the waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate prior to applying the waste.
NARRATIVE OF OPERATION
Page: 7

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients_
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
5. Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "weather
and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies_
8. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit growth_ The potential for salt damage from animal
waste should also be considered.
Page: 8

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to
wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly into water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
the site.
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 9

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
18. If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22. Waste shall be tested within 60 days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied_ Nitrogen shall be the rate - determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when these
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years; Poultry dry
waste application records shall be maintained for.three (3)
years. Waste application records for all other waste shall be
maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North
Carolina regulations.
Page: 10

ANIMAL WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm:RUDCAR FARM
Owner/Manager Agreement
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
North Carolina Division of Water Quality (NCDWQ) before the new
animals are stocked. I (we) also understand that there must be no
discharge of animal waste from this system to surface waters of the
state from a storm event less severe than the 25-year, 24-hour
storm. The approved plan will be filed on -site at the farm office
and at the office of the local Soil and Water Conservation District
and will be available for review by NCDWQ upon request.
Name of Facility Owner: RUDCAR FARMS INC.
(Please pr'
Signatur Z , 4(J ate: 1 2,/j q
Name of ManageAlf different from owner) :
Signature:
Date:
Name of Person Preparing Plan: (Please print)Wilson Spencer
Affiliation:NRCS
Address (Agency):
Signature:
Phone No.
84 County Complex Rd.
Clinton NC 28328
Date:
Page: 11

Waste Utilization Plan
Producer: Rudcar Farms, Inc. County: Sampson
Name of Farm: Rudcar Farms, Inc.
Location: P.O. Box 857
Clinton NC 28328
Phone: [phone]
Type of Operation: Wean -Feed
Number of Animal: 6080
Storage Structure: Anaerobic Lagoon
Method of Application: irrigation
Amount of waste produced per year: 2567 ton/year
Amount of plant available N (PAN) produced/year: 2918 lbs./year
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface water and/or groundwater. The plant nutrients in the animal waste
should be used to reduce the amount of commercial fertilizer required for the crops in the
fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in the implementing your waste utilization plan in order to
maximize the fertilizer value of the waste and to ensure that it is applied in an environmentally
safe manner.
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall not be applied to land eroding at more than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are
established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is
frozen_ Either of these conditions may in runoff to the surface waters which is not
allowed under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor problems.
6. To maximize the value of the nutrients for crops production and to reduce the potential for
pollution, the waste should be applied to a growing crop or applied not more than 30 days
prior to planting a crop or forages breaking dormancy. Injecting the waste or disking will
conserve nutrients and reduce odor problems.
This plan is based on the waste application method shown above. If you choose to change methods
in the future, you need to revise this plan. Nutrient levels for different applications methods are
not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. In some cases you may want to have plant analysis made, which
RECENED
JUN 2 2 2011
DENR-FAYETTEVILLE nEGIMAL CFFi%c

Rudcar Farms, Inc.
Page 2
could allow additional waste to be applied. Provisions shall be made for the area receiving
waste to be flexible so as to accommodate changing waste analysis content and the crop type.
Lime must be applied to maintain pH in the optimum range for specific crop production. This
waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract No.
Field No.
Soil Type
Crop
Code
Yield/Ac
Lbs. N
unit
Acres
Lbs N
Used
Month to
Apply
Lbs. N
Per Ac,
2776
1A
WaB
CB -Graze
4.1
50
1.00
205
MAR-SEP
205
2776
115
WaB
CB -Graze
4.1
50
2.23
457
MAR-SEP
205
2776
2A
WaB
CB -Graze
4.1
50
1.11
228
MAR-SEP
205
2776
2B
WaB
CB -Graze
4.1
50
1.54
316
MAR-SEP
205
2776
3A
WaB
CB -Graze
4.1
50
1.56
320
MAR-SEP
205
2776
3B
WaB
CB -Graze
4.1
50
0.97
199
MAR-SEP
205
2776
4
WaB
CB -Graze
4.1
50
1.77
363
MAR-SEP
205
2776
5
WaB
CB -Graze
4.1
50
1.44
295
MAR-SEP
205
2776
ALL
WaB
OS -Graze
1
5O
11.62
S811
OCT-MAR
I 50
Total 11.62 2964lbs.
Available Nitrogen 2918 lbs.
Surplus or deficit -46 lbs.
Applying the above amount of waste is a big job. You should plan time and have appropriate equipment to apply
the waste in a timely manner.

Rudcar Farms, Inc. Page 3
The applicator is cautioned that P and K may be over applied while meeting the N requirements. In the future,
regulations may require farmers in some parts of North Carolina to have a nutrient management plan that
addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields (i.e. small grain, etc. interseeded in bermudagrass), forage must be removed through
grazing, hay and /or silage. where grazing, plants should be grazed when they reach a height of six to nine
inches. Cattle should be removed when plants are grazed to a height of four inches. In fields where small grain
etc. is to be removed for hay or silage, care should be exercised not to let small grain to reach materity,
especially late in the season ( i.e. April or May) Shading may result if small grain gets too high and this will
definitely interfere with the stand of bermudagrass. This loss of stand will result in reduced yields and less
nitrogen being utilized. Rather than cutting small grain for hay or silage just before heading as is the normal
situation, you are encouraged to cut the small grain earlier. You may want to consider harvesting hay or silage
two to three times during the season, depending on the time small grain is planted in the fall.
The ideal time to interplant small grain, etc. is late September or early October. Drilling is recommended over
broadcasting. Bermudagrass should be grazed or mowed to a height of about two inches before drilling for best
results.
Caution must be exercised in grazing or haying summer annuals under stressed conditions. Nitrate poisoning
may occur in livestock_ Sampling forage or hay for nitrate levels is recommended.
Acres shown in the tables are considered to be the usable acres excluding required buffers, filters strips along
ditches, odd areas unable to be irrigated, and perimeter areas not receiving full application rates due to
equipment limitations. Actual total acres in the field listed may, and most likely will be, more than the acres
shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land application of sludge at agronomic rates.
The sludge will be nutrient rich and will require precautionary measures to prevent over application of nutrients
or other elements. Your production facility will produce approximately 438 lbs. of plant available
nitrogen per year in the sludge.
If you remove sludge every 5 years you will have approximately 2189 lbs. of PAN to utilize. Assuming
you apply this PAN to hybrid bermudagrass hayland at the rate of 300 lbs/acre you will need 7
acres of land. If you apply the sludge to corn at the rate of 125 lbs. of nitrogen per acre you will need 18
acres of land. Please be aware that these are only estmates of the PAN and the land needed. Actual
requirements could vary by 25% depending on the sludge waste analysis, soil types, realistic yields, and
application methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation such that
runoff or ponding occurs. This rate is limited by initial soil moisture content, soil structure, soil texture, water
droplet size, and organic solids. The application amount should not exceed the available water holding capacity

Rudcar Farms, Inc.
Page 4
of the soil at the time of irrigation nor should the plant available nitrogen applied exceed the nitrogen needs of
the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the producer and
irrigation designer to ensure that an irrigation system is installed to properly irrrigate the acres shown in tables.
Failure to apply the recommended rates and amounts of nitrogen shown in the tables may make this plan
invalid.
The following table is provided as a guide for establishing application rates and amounts.
Tract No.
Field No.
Soil Type
Crop
Code
Applic.
Rate(in/hr)
Applic.
Amount
2776
1A
WaB
CB -Graze
0.5
1.0
2776
1B
WaB
CB -Graze
0.5
1.0
2776
2A
WaB
CB -Graze
0.5
1.0
2776
2B
WaB
CB -Graze
0.5
1.0
2776
3A
WaB
CB -Graze
0.5
1.0
2776
3B
WaB
CB -Graze
0.5
1.0
2776
4
WaB
CB -Graze
0.5
1.0
2776
5
WaB
CB -Graze
0.5
1.0
2776
ALL
WaB
OS -Graze
0.5
1.0

Rudcar Farms, Inc.
Page 5
This is the maximum application amount allowed for the soil assuming the amount of nitrogen allowed for the
crop is not over applied. In many situations the application amount shown cannot be applied because of the
nitrogen limitations. The maximum application amount shown can be applied under optimum soil conditions.
Your facility is designed for 180 days of temporary storage and the temporary storage must be removed on the
average of once every 6 months. In no instances should the volume of the waste be stored in your structure
be within the 25 year 24 hour storm storage or one foot of freeboard except in the event of the 25 year 24 hour
storm.
It is the responsibility of the producer and the waste applicator to ensure that the spreader equipment is operated
properly to apply the correct rates shown in the tables. Failure to apply the recommended rates and amounts of
nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you have receive the waste analysis report for assistance in determining the
amount of waste per acre and the proper application rate prior to appling the waste.
NARRATIVE OF OPERATION

Rudcar Farms, Inc. Page 6
WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply waste. If the producer
does not own adequate land to properly dispose of waste, he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner of the facility to
secure an update of the Waste Utilization Plan when there is a change in the operation,
increase in the number of animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climatic conditions, and level
of management, unless there are regulations that restrict the rate of application for other
nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but less than 30 tons per acre per
year providing grass filter strips are installed where runoff leaves the field. (See FOTG
standard 393 - Filter Strip).
5. Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland,
the waste may be broadcast provided the application does not occur during a season
prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate that runoff
does not occur offsite or to the surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor or flies.
& Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a
high potentual for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste
shall not be applied more than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residenrial property boundary
and from any perennial stream or river (other than an irrigation ditch or canal. Animal
waste other than swine waste from facilities sited on or after October 1, 1995), shall not be
applied closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips).

Rudcar Farms, Inc. Page 7
REQUIRED SPECIFICATIONS
(continued)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those owned
by he landowner.
14. Waste shall be applied in a manner not to reach other property and public right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site by a "technical specialist".
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that causes no runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
17. A protective cover of appropriate vegtation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced as necessary to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidences of
erosion, leakage or discharge.
18_ If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illigal discharge, pollution and erosion.
19. Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20. Animal waste can be used in a rotation that includes vegetation and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied pre -plant with no further applications of animal waste
during the crop season.
21. Highly visible markers shall be installed to mark the top and the bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste analysis records shall be kept
for five (5) years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina regulations.

Page 8
WASTE UTILI7ATION PLAN AGREEMENT
Name of Farm: Rudcar Farms, Inc.
Owner/Manager Agreement Rudcar Farms, Inc.
I (we) understand and will follow and implement the specifications and the operation and maintenance proce-
dures established in the approved animal waste utilization plan for the farm named above. I (we) know that any
expansion to the existing design capacity of the waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the North Carolina Division of Water Quality
before the new animals are stocked. i (we) also understand that there must be no discharge of animal waste
from this system to the surface waters of the state from a storm event less severe than the 25-year, 24 hour
storm.The approved plan will be fled on -site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner:
Signature:
Rudcar Farms, Inc.
Name of Manager (If different from owner)
Signature
Name of Person Preparing Plan: G. Glenn Clifton
Affiliation: Prestage Farms, Inc. Phone: [phone]
Address: P.O. Box 438
Clinton, NC 28329
Signature: _ yam_ C� • .
Date: b !L j ! 1
Date:
Date: �jl6 t I

Land owner:
Irrigation System
Designation:
Wetted Diameter:
Spacing:
Hydrant Layout:
Hard Hose Traveling Gun System
Rudcar Farms Facility Number: 82-35
X Existing Irrigation System New/Expanding
Irrigation System
170 feet
94% * Use 90% of wetted diameter = 153 feet
160 feet
X Multiple Hydrants Single Hydrant
Pull
Number
* Lane
Spacing
Pull
Length
Location
Ext/Int
Middle
Start
End
Stop
End
Total
Acres
1A
153
225
Single
0.79
0.21
1.00
18
153
575
Single
2.02
0.21
2.23
2A
153
255
Single
0.90
0.21
1.11
213
153
380
Single
1.33
0.21
1.54
3A
153
385
Single
1.35
0.21
1.56
3B
153
215
Single
0.76
0.21
0.97
4
153
385
Single
1.35
0.21
0.21
1.77
5
153
350
Single
1.23
0.21
1.44
Total
F 11.62
Computed By: Q tM GIPID,l

IRRIGATION SYSTEM PARAMETERS
Land Owner
Address:
Rudcar Farms
P.O. Box 857
Rate: 06/15/2011
Clinton NC Facility No. 82-35
Telephone: [phone]
County: Sampson
TABLE 1- Field Specifications
Field No.
and/or
Pull No.
Maximum
Usable
Size of
Field
Soil Type
Slope
N
Crop(s)
Maximum
Application
Rate
(in/hr)
Maximum
Application
per Irrigation
Cycle
(inches)
lA
1.00
WaB
0-6
CB -Graze
0.6
1.0
1B
2.23
WaB
0-6
CB -Graze
0.6
1.0
2A
1.11
WaB
0-6
CB -Graze
0.6
1.0
2B
1.54
WaB
0-6
CB -Graze
0.6
1.0
3A
1.56
WaB
0-6
CB -Graze
0.6
1.0
3B
0.97
WaB
0-6
CB -Graze
0.6
1.0
4
1.77
WaB
0-6
CB -Graze
0.6
1.0
5
1.44
WaB
0-6
CB -Graze
0.6
1.0
11.62
Computed By: (�, G'L��In1 0 L i r7cFl

p�-�•t �^ie �
-�� `'T,5 a,•'i +'f
. �, '' Y ' • . r "S •". f •. i 1
Rudcar Farms
SprayField(s)
Sampson County
' 3:r ,- ♦ is �5� ����•� � 1j� ,1: 5_, � 1 ' ~� tr
' � � � l 3` a u �'��3s�j,,R �V'��t drLt," } '• w Ye • ' 'T
' - ` ,• S: r"f S:v1., 'a iLs•�' •r jyyy
,,,�}'i
1►'"'
. � u �'�M1�a ;WTI ���. y ,..� ,+a r?;,���•rr� ' t' � :.�
1, U i,ry• i h C �3 r - !,
SF e'`�,�+�'rrir�i,f,k '�!",Issi' ti'• �� All+.
, 1 � Y' J•.e'• t - L ,' ,',l �� � Y � a • � ` •# ill♦,f
' n t .i - � "+ � . CFI , f i." •,.���' .':.1 s...
_ n5
'� . rr. 1 5 ' � � '�. :� E'+ t3 1 r `� - 1 '���•{,�J �r •' r�.. � t,r � f � �+,.+ � _�y `wx J
3A., ":E'i0 l•1 t! t.t i. rh. +. i
38 '
... i .. L1E� t. •'; '� ''7' 1 Ai l�" ': a: lk '"S AS F"�,.��5 '',�!i,rr. - i y- a.�, .J ..�gl
�34.:, d` yk. 1!,. r i Fir _i Pq 5 S •'I..,ti
r i Z inch 200 feet"
E'Yir J.�.. t' E '' i� v A: '.l;'l ♦ .. ',i' ."4' ` .n r J i F -¢ .E _-!l 1, wi �._ x. ♦ . +� F .J/I .•f''•� .. . it-�' Y r•, '!} { A '�k
-R. l - +• a - .r .. � t.

Pa_&rA6E
Plan Amendment to Include S&WCC Chronic Rainfall Practices and Standards through Marcie 31, 2000
1. if this facility can comply with its existing permit and CAWMP it must do so.
2. Temporary Addition of New Sprayfields (*) (Check appropriate boxes.)
j] A. acres of cropland. List crop types used:
[j B. acres of hardwood woodland @ 100 lbs PAN / acre added.
0 C. acres of pine woodland added @ 60 lbs PAN / acre added.
- —09 _.
3. Summer Perennial Grass (Check appropriate box.)
€}'A. Application window extended for /3 acres of perennial grass until first killing frost-
(] B_ An additional 50 lbs of PAN applied to acres of perennial grass prior to killing frost.
4. PAN Application Increased for Small Grains & Winter Grasses to be harvested. (Check appropriate box.)
WA_ PAN application increased up to 200 lbs per acre for / 3 acres of small grains or winter grasses to be harvested.
0 B. PAN application increased up to 150 lbs. per acre for acres of overseeded summer perennial included in 3. B.
S. Waste Analysis (Check appropriate box.)
B'C Prim to December 12, 1999 the calculation of PAN will be based on a 35% reduction of the last analysis taken
prior to the first 25 year 24 hour storm event- (Current waste analysis must be used after Dec. 1' .)
Q B_ Use current waste analysis to determine PAN.
6. Required - Maximum Nitrogen Utilization Measures for Small Grains and Winter Grasses_
A. Use of higher seeding rates,
B. Timely harvest of forage to increase yield, and
C. Irrigating during periods of warmer weather.
7. Required - Irrigation Management Techniques to Reduce Runoff and Ponding Potential_
A. Making frequent, light irrigation applications, and
B. Not irrigating immediately before predicted rainfall.
8. The owner I managei is required to manage the movement of animals to and from the facility to miaimize environmental
impacts, ensure compliance with the facility's permit and amended CAWMP, and avoid discharge to surface waters.
9. Authorization to use the additional practices included in this amendment expires if a facility discharges to surface waters.
Any discharge is a violation and may result in an enforcement action.
10. The owner / operator is required to keep records of all waste applications.
11. This revision must include a map or sketch of new land application areas.
Facilitv Number -
e r� -,— r SZ Ars, 0 r\ t ( � S--,
Facibiry Own / Manager Name (PRINT)
Facility Vier / Manager Signature
Date / / —
_RL4JQ_r�'<_
Facility Name
G C, LE N N C L t F-Tn n1
Technical Specialist Name (PRIN'T)
Technical Specialist Signature
Date 1_1130199
This document must be filed at the SWCD office and be attached to the facilities CAWMP
and be available for inspection at the facility.
(*) New temporary sprayfielcis must meet applicable buffer and setback requirements. Waste must not be applied to wetlands.
1111,V1000

�, 7

Information contained in this database is from non agency sources and is considered unconfirmed
Farm Emergency Call Forte
Farm Number
182 1
—
Date
-
Farm Name
Time
IRudcar Farms Inc
Owner First Name
Call Number
1673
Owner Last Name
IRudcar Farms Inc
p Reporting p Complaint
Source
I
Plan Due Date Date Plan Date Freeboar
1Mr. Carr
Inches (7 equals blank) Received Level OK
Breached
Q Yes O No
Freeboard Lagoonl
Depopulated
Q Yes O No
Freeboard Lagoonl
Overflowed
Q Yes Q O
Freeboard Lagoon3
LOIssue
10 Yes Q No
PermissionToPump
Q Yes ONO
Freeboard Lagoon4
Inundated
p Yes O o
Freeboard Lagoon5
Flooded
Q Yes Q No
Freeboard Lagoonfi
Pumping Equipment
Q Yes ONO
Commentsn Or.O .. y.. O ery...rQ.wn...................................................................................... .....
-AT .............................................................................-................................................................................................................................
..................................................................................................................................................................................................I.....................
........................................................................................................................................................................................................I...............

NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
FAYETTEVILLE REGIONAL OFFICE
DIVISION OF WATER QUALITY
July 28, 1999
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Rudcar Farms, Inc.
Attn.: Jim Carr
PO Box 857
Clinton, NC 28328
SUBJECT: LAGOON SEEPAGE
Rudcar Farms, Inc.
Facility No. 82 - 35
Sampson County
Dear Mr. Carr:
During the most recent visit to your facility, staff from the Division of Water Quality
(DWQ) at the Fayetteville Regional Office (FRO) observed seepage from a lagoon structure
located on your farm. As a result of this observation, a nutrient sample was collected from
the seepage area to verity the presence of waste. The sample results, attached, did verify
the presence of wastewater within the seepage area.
In order to safeguard the environment from further discharges of wastewater and the
potential catastrophic failure of the lagoon structure you are asked to immediately contact a
Professional Engineer to insure the integrity of the structure. The evaluation should include
a statement by your engineer indicating the structural stability of the lagoon and whether or
not the structure poses a threat to the environment. If the engineering evaluation reveals that
corrective actions are necessary to safeguard the environment, you are asked to submit a
plan of action to correct the noted problem(s) as soon as possible.
If the lagoon structure is found to be seeping without the threat of failure, other impacts
to both surface water and groundwater must be controlled. Your engineer should coordinate
these activities with the FRO DWQ Water Quality and Groundwater Sections. The contacts
at the FRO are Jeffery Brown with the Water Quality Section and Art Barnhardt with the
Groundwater Section.
ZZ5 GREEN STREET, SUITE 714, FAYETTEVILLE, NORTH CAROLINA 28301 -5043
PHONE [phone] FAX [phone]
AN EQUAL OPPORTUNITY / AFFIRMATIVE ACTION EMPLOYER - 50% RECYCLED/10% POST -CONSUMER PAPER

Page 2
Rudcar Farms, Inc.
July 28, 1999
Please notify this office in writing at the letterhead address as soon as possible following the evaluation,
but at least within 60 days of receipt of this letter with the results of the engineering evaluation. Your response
should also include a plan of action to correct the noted problem(s). Nothing in this letter should be taken as
absolving this facility of the responsibility and liability of any violations that have or may result from this
situation. If you have any questions concerning this matter, please do not hesitate to contact either Art
Barnhardt, Regional Groundwater Supervisor, or myself at [phone].
Sincerely,
'yam
Jeffery Brown
Environmental Engineer
cc: Sonya Avant - Compliance Group
Audrey Oxendine - FRO DSWC
Wilson Spencer - Sampson Co. NRCS
Central Files
Glenn Clifton - Prestage Farms

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
Michael F. Easley, Governor
William G. Ross Jr., Secretary
Kerr T. Stevens, Director
April 4, 2001
MEMORANDUM
To: Regional Water Quality Supervisor
F?WAA
Jam
NCDENR
1Ncwz-rH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
'APR 9 2001
From: Sonya Avant, Environmental Engineer ,d)eA_ REG. O FIOE
Non -Discharge Compliance and Enforcement Unit
Subject: Wettable Acre Determinations for Certified and Permitted Operations
Attached is a list of the facilities in your respective regions that have been selected to receive
notification letters advising them that they have been flagged or pended for the month of March.
Each facility will be given written notice via certified mail. The notice will include a copy of the
certification form and a deadline for response.
I will also be sending copies of the final monthly list of selected facilities to the Division of Soil
and Water Conservation Operation Reviewers and Soil Water Conservation District Offices each
month along with an updated copy of all facilities in that county that have been either flagged or
pended. This will hopefully enable the Districts to be better able to schedule their workloads.
If you have any questions, please contact me at 733-5083 extension 571, or
[e-mail].
cc: Coleen Sullins
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10%a post -consumer paper

Facilities Flagged/Pended for April 6, 2001
Facility Flagged/Pending
Number Owner Farm Name Address Status WA PAN deficit WA Visit Date Integrator
ERR
09 --- 66 Darrell Coble 2209 Old Fay Rd P2 952 5/17119" Murphy Family Farms
....................................
Garland NC 28441 .
Harvey Coble Nursery
09 — 132 Darryl Hardee 3281 Rosindale Rd Fl 889 5/19/1999 Murphy Family Farms
. Clarkton NC 28433
Terra Nova Limited
82 — 35 Rudcar Farms Inc PO Box 857 F4 393.72 4/14/1999 Prestage Farms
Clinton NC 28328
Rudcar Farms Inc
82 -- 88 Ward Parker 9052 Lake Point Or F4 491.49 4/21119" Prestage Farms
Clinton NC 28328
Ward Parker Form
82 — 112 Donnie Bradsher 2950 Moseley Ave F4 557 4/22/1999 Murphy Family Farms
Clinton NC 28328
Bradsher Farms 1, 2 & 3
82 -- 164 Billy Tyndall 6431 N US 421 Hwy F4
Clinton NC 28328
B&B'lryndall Form
409
5111/19" Prestage Farms
82 — 184 Sherwood E Allcox 255 Fork Lake Drive F4 527.25 4/14/19" Prestage Farms
Clinton NC 28328
S.E.A. Livestock
82 -- 186 Herbert G. Bowden 11294 Hobbton Highway F2 516 4/26/1999 Prestage Farms
. Clinton NC 28328
Herbert C Bowden Farm

Facilities Flagged/Pended for April 6, 2001
Facility Flagged/Pending
Number Owner / Farm Name Address Status WA PAN deficit WA Visit Dale Integrator `
82 — 189 Roy Horne 73 D&H Lane P2 497 6/22/1999 dogwood Farms
.................................... Turkey NC 28393
D&H Farm
82 -- 199 Glenn D. Jones 81 Hardy Lane F4 577.8 5/11/1999 Prestage Farms
Clinton NC 28328
Glenn D. Jones Farm
82 — 318 Carroll's Foods Inc PO Box 856 F2 4710 2/19/1999 Carroll's Foods Inc
Warsaw NC 28398
2703
82 — 319 Carroll's Foods Inc PO Box 856 F2 11428 2118/19" Carroll's Foods Inc
, Warsaw NC 28398
2702
82 — 323 John Hendrix t45 Register -Sutton Road F2 575 6/22/1999
....................................
Rose Hill NC 28458
John Hendrix
82 .-. 335 Rexton Simmons 1128 HONEYCUT*1' F4 494 5/5/1999 Murphy Family Forms
. CLINTON, 28328
R&R Farms
82 — 367 Zack McCulfen,111.
D&Z Farms
82 — 376 David Sinclair
David Sinclair Farm
1058 Wynn Road F4
Clinton NC 28328
6978 Faison Hwy. F4
Faison NC 28341
423
4/22/1999 Preslage Farms
512.5 3/15/1999 Carroll's Foods, Inc.

Facilities Flagged/Pended for April 6, 2001
Facility Flagged/Pending
Number Owner / Farm Name Address Status WA PAN deficit WA Visit Date Integrator
82 .— 426 Ben Parham 2391 Isaac Weeks Road F2 552.9684 4122/19" Prestage Farms
Clinton NC 28328
Parham Farms
B2 — 439 James Greg Horrell
9461 Tomahawk Highway F4
529 3129119" Murphy Family Farms
Tomahawk NC 28444
Greg Horrell Farm #2 & Addition
82 —444 Nash Johnson
PO Box 25 F4
398 4/5/1999 Murphy Family Farms
Clinton NC 28328
Boykin Lake Farm
82 -- 448 Richard Whitfield
1670 Kenan Weeks Rd F4
504.99 4/29119" Murphy Family Farms
Newton Grove 28366
Whitfield Livestock #1
82 — 466 Carroll's Foods Inc PO Box 856 F2 8411 2/16/1999 Carroll's Foods Inc
Warsaw NC 28398
2537 and 2538
82 — 472 Carroll's Foods Inc PO Box 856 F2 $275 2/17/1999 Carroll's Foods Inc
Warsaw NC 28398
2142
82 -- 473 Carroll's Foods Inc PO Box 856 F2 3597 2/16/1999 Carroll's Foods Inc
Warsaw NC 28398
2141
82 —475 Carroll's Foods Inc PO Box 856 F4 16510 2/15/19" Carroll's Foods Inc
Warsaw NC 28398
2106 and 2104 }
5 �C,-6c�

Facilities Flagged/Pended for April 6, 2001
Facility Flagged/l'ending
Number Owner / Farm Name Address Status WA PAN deficit WA Visit Dale Integrator
82 —497 Carroll's Foods Inc PO Box 856 F4 3650 2/18/1"9 Carroll's Foods Inc
.................................... Warsaw NC 29398
2122
82 — 598 Robert Naylor 2988 Church Road F4 393.15 4/14/1999 Murphy Family Farms
Clinton NC 28328
Robert Naylor R3
82 — 611 Murk & Lora Godwin 1177 Eldridge Rd F2
.................................... Newton Grove 28366
Godwin Nursery SCD #1 & 2
404
3/10/1999 Murphy Family Farms
82 — 619 Elbert Pearsall 997 Simmons Road F4 520 4/26119" Prestage Farms
. Clinton NC 28328
Elbert Pearsall Form
82 — 621 Jody Coombs P.O. Box 612 F4 463.4 4/21/1999 Prestage Farms
Clinton NC 28329
Joshua Coombs Farm

State of North Carolina
Department of Environment
and Natural Resources
Michael F. Easley, Governor
William G. Ross Jr., Secretary
Kerr T. Stevens, Director
CERTIFIED MAIL
RETURN RECEIPT REOUESTED
Rudcar Farms Inc
Rudcar Farms Inc
PO Box 857
Clinton NC 28328
Dear Rudcar Farms Inc:
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
April 6, 200I
d-,11a.E1,I'�D
rAPR 16 not
Subject: Notification for Wettable Acre Determination
Animal Waste Management System
Rudcar Farms Inc
Facility Number 82-35
Sampson County
A letter dated January 15, 1999 was sent to advise you about concerns associated with Certified Animal
Waste Management Plans and the method by which the irrigated acres within the plans were calculated. Only
the acres that are wetted can be credited in the waste management plan as receiving waste application. Any
acreage within the plan that can not be reached by waste application equipment can not be used as part of your
plan.
An evaluation by Scott Faircloth on 4/14/99 was made to review the actual number of acres at your
facility that receive animal waste during land application. The evaluation of your facility has yielded one of
the following two results as indicated by the box marked with an "X".
Category 1:
❑ The evaluation of your facility could not be completed due to a lack of information. Please
contact your Technical Specialist to assist in providing Scott Faircloth the necessary
information to potentially exempt your facility from undergoing a complete wettable acre
determination. Please submit this information to Scott Faircloth, at 225 Green Street, Suite
714, Fayetteville, NC 28301, within in 90 days of the receipt of this letter. If you have any
questions please contact Scott Faircloth at [phone]. If within 90 days you are
unable to provide Scott Faircloth with the information you are automatically required
to complete a Wettable Acre Determination as described by Category 2 below, within
180 days of receipt of this letter.
1617 Mail service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

Notification for Wettable Acre Determination
Animal Waste Management System
Page 2
Category 2:
Your facility has been identified by the Department of Environment and Natural Resources
as a facility that may have overestimated the number of acres actually receiving animal
waste. Therefore, some or all of your fields may be exceeding the allowable loading rates
set in your Certified Animal Waste Management Plan.
In order to resolve this issue, please contact a designated Technical Specialist to have him
or her conduct a Wettable Acre Determination for your facility. The Technical Specialist must
be one that has been approved by the Soil and Water Conservation Commission to conduct
Wettable Acre Determinations. Many Technical Specialist with the N.C. Cooperative Extension
Service, the Soil and Water Conservation Districts, the Natural Resources Conservation
Service, and the Division of Soil and Water Conservation have received this special
designation. You may also contact a private Technical Specialist who has received this
designation, or a Professional Engineer.
All needed modifications to your Animal Waste Management System must be made and
the Wettable Acres Determination Certification must be returned to DWQ within the next
180 days. If the needed modifications are not made and if the form is not returned within the
required time, DWQ will be forced to take appropriate enforcement actions to bring this facility
into compliance. These actions may include civil penalty assessments, permit revocation,
and/or injunctive relief.
Once a Wettable Acre Determination has been completed, a copy of the attached Wettable
Acre Determination Certification must be submitted to the address listed on the form. Please
note that both the owner and the Technical Specialist must sign the certification. A copy of all
the Wettable Acre Determination documentation that applies to your Waste Utilization Plan
must be kept at your facility. DWQ and the Division of Soil & Water Conservation Staff will
review all documentation during their annual visit of your facility. An additional copy must by
kept on file at the local Soil & Water Conservation District Office. Please note that if you install
or modify your irrigation system, a designated Irrigation Specialist or a Professional Engineer
must also sign the Wettable Acre Determination Certification.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Sonya Avant of our
Central Office staff at [phone] ext. 571.
Sincerely,
Kerr T. Stevens
cc: Fayetteville Regional Office
Sampson County Soil and Water Conservation District
Facility File
Prestaae Fanns