820030_CORRESPONDENCE_20171231

NUH I H UAHULINA
Department of Environmental Qual

AnimaI Waste N-Ianagement Plan Certification
(?tes;e woe or Drill( all inrtxmatit)n dmc tints nt)c reuuire a,skinatuae,
. Jsdney ar`':: i` a Or Expanded"' (Please circle one)
General In Formation:
`a:-ne ar Farm: Cc— /7ra-,-•,1, S Facii v No:,-:Sj----�L
Ow•ne-r-W Name: �.� �-- �.r.-► 1 �.�,.. s P`�or:: a:glo53� ��f
-Ivlailina Address:
Ll
Farm Location:
Councy Farm is located
Lacic�_e�e a..r?d Longitude: 3A�
�Z l - Zd P8L Iricegracor: jvV--1f
Please acacia a copy of a councvLoad
map with location ide icifled and describe bciow (Be specific: road
names, directions, mileposc.ecc.): e11 1ti�
Cs� $ . sY; ► IeS 4b
513.L
S1Y a.A Qnkla.ncP n n r � e. h�
�ouwc�nr�s1S 0 r� $t7211 31 ', Cta (3q U^ % 14L- At�-q� to
r)aration Descriotion:
Type of 5s ilze M. of Animals
Type Or Pouirrr: Xa. of .-knirrals Tv.;e of C.-rrle ;fro. of Animals
_' %Vean to F -es.ier
:2 Laver
+1'=cede: to . iaish11i all 0
:2 Pulps
_ ----C v to wean
-' `` �'.. to . ei
�.' =a_r u•v co riai511
or/ter Tvpe of �i.."esro C.4.: v:ru ,_rqr.:nir.C1P:
_ Giics
Boa-.
Acrea _ .ova: fable for Apolicac:on: Acre:g!:� 1 �°
`:umber of L coons 1 Storage ?cads._ Toca1 Capac;cy:'titI QZ5 Cubic=...(f==)
xt: drahis oresenc on'-4: farm ITS or (please circle one)
If YE3. are subsurface d =ins present in the ama of the LAG CON or SPRAY FIELD (rteas. !e onc)
.. s. 1s Y. '. . ..: Y. FI IM i. lM 1M ............. M - - - - — - - - - A" •. 14 •. }. 1!. F. }.1 — ,n. +{ ,y ................
O%vner- / tilana;er Affreement
Lilac all the above information is currect and will be uvanted ucun cianii:j_s. l (.e) understar d the Operation
a.nd Maintenance procedures dsablishe.: in the approved ani..ial .vast-- managemenc plan for the ---n named above and
in, piemcnt these procedures. 1 (we) :nosy that any exoansiun to the existing design cap;:city of the waste treatment aad
s10ra2_ s•.•ste :1 or constr.tcdun of nV.v Facilities will require a new cerd:lcadon to be subaticted to the Division uC
Ntanaaement before the new animals are stocked. I (w,:) understand that Ye:e must be :o discharge oC
anir: a_r wa_;c_ from the storage or appiicadon system to surface waters of the state ei_her diu-,My through a than-aiate
conve.•a ce or from a storm t :nc less severe than the ?j-year. 2--hour storm and there crust not be run-off from the
acplicz on of animal waste. I (tve) understand chat run-off of pullu=r-s from lounging :rid heap•;+ usd areas must be
miaic-;zed using technical sc=,dards developed by the :Natural Resources Conservation Serrr.. The approved plan will be
tile•! at =' a tarot and at the office of the local Soil and Water Cuaser:aLion District. I (w.) know that any modification
taus[ be aporoved by a ccc�m. cal specialist and submitted to ciae Soil and eater Conserradon District prior to
�:.cie^e^•_ciun. A cban2e ir. 1=d ownership requires written noci_:cation to DENT or a avx certiicadon of the approved
plan i; c:.w.?cd) within 66 days of a tide transte,. r
`arne of Land
Signw:tur, e:_
Narnz of tiI
Signature:
er(if differcru from owner):
Date:
Date:
.-1«'C -- August 1. 1997

Technical Specialist Certification
.(. .•ems a technical specialist designated by the North Carolina Sail and water Conserv;ttiun Commission pursuant to 15.E
NCAC 6r= .COOS. I certify that the animal waste management system for the farm named above -has an animal waste
management plan that meets or exceeds standards and specifications of the Division of Envimnatental :Maria$! nt
(DEN) as s{:ecified in 15A NCAC 2E•E.0217 and the USDA —Natural Resources Conser.adon Sdrvict (,NRCS) =d/or the
NorTh Carolina Soil and Water Conservation Commission pursuant to 15A NCCAC 2H.02!7 and 15.E iYC kC hF .000I-
.0003. The following elements are included in the plan as applicable. While each categor+ designates a technical specialist
who may sisn each certification (SO. SE. �VUP, RC, 1), the technical specialist should only certify parts for w6icti they are
technic3hy competent.
11. Certifcation of Design
A) Collection. Storage. Treatment System
Check r!t_ aapropriare box
Ec cirio•tacilicv wichout rzcrotic (SD orWTUP)
Starage volume is adequate for operation capacity: storage capability c;snsisla% with waste utilization
-�ruqutrements.
a' `ew. expanded ter rerrntitted,taclliiv (SD}
Animal waste sturage and treatment structures. such as but not limited co collection systeats. lagoons and ponds.
have been designed to =.t or exceed the minimum standards and speci icaut} � ctis►"""1ii�
* V esr&►1 APFIrou t P Sy Four A • MI "A t -�,? e- , V-1" y - .
Name of Technical Specialist (Please Prirtt):.J. 1-6AL— Tuc*�el
n�2MS —Date
Addraess (agency 0- 3e,>C -7�6,gefe ►i 1t.1 A-Ic-
ho�'��• r?.1IL
S ~
B) Land Aoolication Site (WLTP)
i he plan provites for minLmuam separations (buffers): adequate amount of land fer waste utilization: chosen crop is
soluble for waste m: rasemeat: hvdraulic and nutrient loading rates.
Name of Technical Specialist (Please Princ):
Ar=iiizr-tin �.. - ✓ Dace Work Cornaie[ed:_ 1 ;3-.It/I -1
Address (Agen. 7 Ike e_ Phone NV:4)Q)j-1M x I i 1
SWr<::��:� Date:
C) R u n o ff Contras Fr(
Check rife apprapriare box
Factlicv without exterior lots (SD or WliP or RC)
TLtis facility does nct ccrLiin any exterior lots.
•Z[ Facil'tcv with exce�or lots (RC)
,Methods to minimize the run off of pollutants from loungincy and heavy use arms h ve be:n designed in
accordance with technical standards developed by INRCS.
Narne of Technical Specialist (Please Print):
Atiiiat;on Alm
Address (Aden
A\VC - .�U t
rbec-
Date Work Cornple'red:_j;#ll/ `f
Phone No.:
Date: / 1 / C� 7

D). Aloraiication_and HandlinaEquipment
Check rise uppropriare box
XISc ,^ nr x n ''n rr 'ili v tvl x-.5 n^ W;1.S ii -C'7f1 �l ❑ (`VL9 or 1)
Animal waste applicadun equipment specified in the plan his been either tied calibratf d or evaluated in
accordance with e;isting design charts and tables and is able to apply waste as necessary to accottirtiudate the
wasce management plan: (existing application equipment can cover the area require by the plan at races not to
exceed either d` c sce_ired hydraulic or nut:riem loading races. a schedule for tsarina of applications has been
established: required buff; rs can be maintained and calibration and adjustment gui {t =c. are contained as Bart of
the plan).
.:1 New._exnnnded. ncti-istina racijjcv wi o xU' c wasm aonlicition eatrimment forimrav irr,?ntion. (I?
Animal waste application equipment specified in the plan has been designed to apply waste as necessary to
accommodate the was,: management plan. (proposed application equipment can cover the =a required by the
plan at races not to exceed either the specified hydraulic or nutrient loading rates; a schedula for tuning of
applications has been established. required butlers can be maintained: calibration and adjustment guidance are
contained as part of the plan).
;.! �,t•.v. e'S.L'_a11. e5L or ezistina facility %vUour eniscin; w are euuia== For Unit snrr_din� nor t�sin
i"Slt=irrutltion_. (W ? or D
Animal %vaste application equipment specified in the plan has been selected to apply ts-aste as necessary to
accornmotiata the waste managemenc plan: (proposed application equipment care cover the area required by the
plan at rates not to exce_d either the specified hydraulic or nutrient luading tees: a schedule for timing of
applications has bets established: required buffers can be maintained; caiibradun and adjismrent guidance are
contained as par: of the plan).
Name of Technical Specialist (Plelse Print): s L c s
Ariliz.iar, M r Daft: «'ar.�
AddLeSS ( =c:e5C ): Pion_ `0.
E)
i n: was a manapmvu plan for this facility includes a Waste Management Odor C_ntrel Cht.visr. an Insect
Conccol ChecUisc a Nlor: iicv Manazemenc Chec::list and an Emereenev action ?fan. Sources of both odors and
Lns,-cts have been tvaluzced with respect to this site and Best i`,Ianagement tv Minirnize Odors and Besc
Management ?mcdces to Control Insects have been se!ecred a.^.d included in Lh;: waste manasim-^.t plan. Both the
Mortality Nlanasemenc Plan and the Emerizency Action ?lap-kre yompiete and can br impltmeaced by this facility.
Name of Technical Specialist (Please Print):
A.f ftL::uun-,AAr
A�ci__ss (Axe
Date «'or Ccrr,r1!e'2f: f a4t /S 7
Phone
D9 7
F) or ExpandingS%-tine Farm
The folIo%tche
g signature block is only to be toed for new or a cpardin� stivirte farms that bin catutruc:ian after Junr
21, 1996. facility was built before June 11. 1996, when %rss it constructed or lust
e` pand IIId) .�
I (1-ve) C%:-;fy that I (we') have atteipced to contact by certified mail a.!I adjoining prose^r otre s and ail property owners
who a%.—,, property located across a public road. street. or highway from this new ore ;pandiag s%ire fart. The notice w-as
in camp Hance with the mquin—ments of YCGS 106-305. A copy of t"e notice and a list of the proFerre owners notified is
aC4:t:!:C•.l .
Name of Land Owner:
Signature: Date:
Nam of NIanager(i`diffe:encfrom owner):
Si -nature:
AVY"C -- ..u7ust 1. 1997
Date:

.II.£. Certification of Installation
A) Collection. Siorbge. Treatment Installation
V"env. ext�tln�ed ar recrotiued tat:ility (SI)
Animal waste storage and treatment structures. such as but not limited to lnecoas =d ponds. have been installed
in accordance with the approved plan to meet or exceed the minimum standa:ds and specifications.
For existing facilities without retrofits, no certification is necessary.
ti'ame of Technical Specialist (Please Print): J - AJea
Affili-ation 1M Fr- Date Work
Address (Agency):.„
Signacure:
B) Land Application Site (WUP)
Check Trite appropriate bo.:
.sQ
J%J411411r►►
LN iARe!
ion `o SEAL' �
ffitz: �
�vAi I y 4 �,`•
The cropping srsta.n is in place on all lured as specil:ied in the :ininui waste management plan.
r1 Conditional approval: all required land as specified in the plan is clezrvd for planting: the cropping syscetn
as specified in Le waste utilization plan has not been established and the owner has commits-d to establish the
,eezetation as spec'.:ied in the plan by (monrhldayi c_); the proposed cover crop is
appropriate fercompliance -.with the wascesdlizacion plain.
Also chc.K this box if atlarooriace
if the c:aopLas system as specified in the plan can not be established cn ne-xly cleared land within 30 da,.rs
of this ce:dtication, the oume: has committed to establish an interim crop ter.msion control:
.Na-me of Technical Soeda st' leas Pr:
:natio n ^ f � "
Address (Ave
Sisnatur<�
"C-C,- l e--
Date Work- Cor:.�t.:ed: I, �-%�fI`i 7
F.CF;a No..
Dar!: /YJZ 7
This follo ing sign turn block is oniv to be used when the box for conditional approval in III. B
above has been the lied.
I (we) CerAfy that I (%ve) Lave committed co establish the c:ogping system as specified in ny(our) wake uilization plan.
and if appropriate to establish the inumm crop for erosion controE. and «rill submit to DENT z ve^ncadun of completion
mart a T ethnical Specialist within 1. calendar days following the relate specified in the conrlitiun:.l cc.ticicacian. I (toe)
realize t: ac failure to submit this venflicadon is a violation of the waste managetne:it plan and wiii subject me (us) to an
enforcement action from DEM.
Name, of Land Owner:
Signature: Date:
Name of Manager (if different from owner):
Signature: Date:
A%VC -- Au-zusE 1. 199 7 4

C) Runoff,Controls from Exterior Lots (RC)
Facilicy with exterior lots
�Iet loth Lo rninimize dic run off of pollutants frorn lounging and heavy use areas ha:e bc_n installed as specified
in Lhe plan.
Far facilities without exterior tots, no cerrijcation is necessary.
Name of Technical Specialist (Please Print):
Affiliation Data Work Comole�ed:
Address (Aeency): Phone -No.:
Sianatur.-: Dale:
D) Application and Handlina Equipment installation (WUP or Z)
Chect the aa�opriare block -
.Animal waste application and handling equipment speciried in the plan is on site and mady for use:
calibration and adiuscnent materials have been provided to die owners and are contained as pcLrt of the plan.
." animal waste applicadon and handling equipment sp"-iftcd in the plan h;is noc beta irwallcd but the owner
has propoed leasing or third party applicadon and has provided a signed cont.-act: equipatem specified in
the conu-acc agrees MO die requirements of the plan: required buffers can be maintained: calibration and
adjustment guidance have be_tt provided to the owners and are contained as part of the plan.
Z" Conditional approval: ,Animal waste application and handling equipmenc specified in the plan has
bean purchased and will be on site and ins a[led by (stoat ldalh•ear): theme is adequate
storage to hold the waste until the equipment is ins•"led and urdl tl;e ,rite ran be land applied in
accordance with t:^.e cropping system concained in the plan: and caliat=tiea ar...:d}usmttnc guidance have
been provide! to tue owner and are contained as pan of Lhe,pian,
Name of Technical Specialist (Please Print)
Address (A
s igrlacl—'re:L
IC
Date Wark Comaie�c:
Notre No.
1�,Iyl q --7
The follo; re block is only to be used when the box for conditional aoproval in III D
above has een checked.
I (we) ceI,;., that I (we) have committed to purchase the animal wasteaoplicadcn andhandling equipment as
sC;C-;&E7. �. my (our) waste maragement plan and will submit to DEM a verification of de!iver: and installation
from a Technical -Specialist wiLNa 15 calendar days following the crate specified in the conditional certification. I
(eve) realizt rhat failure to submit this ve:-itic:uion is a Violscion or the waste manaverneat plan and will subjm*t me
WS) to an ert.trcement action GOm DE.M.
Name of Land Owner:
Signature: Date:
dame of Manager (if different from owner):
Signature:
Date:
E) Odor Control. Insect Control and Mortality Management (SD. SI, WL-P. RC or it
".it;hecs to cannot odors and insects as specified in the Plan have beet ins all_+ and are L)pe:-ldonai. ire
mort: t icv nnana2e:nent system as specified in the Plan has also �eea }nstqled and is epe.'"tion fl.
itiame of Technical Specialist ((?leaseePri
Acid. -ass {.
Date Work Completed: h�Nl9 I —
Phone No.:
Date: � 9
_ NVC -- Au%J6�1 1, 199

Please return the completed form to the Division of Water Quality at the follolsing address;
Department of Environment, Health, and Natural Resources
Division Of Water Quality
Water Quality Section, Compliance Group
P.O. Box 39535
Raleigh, NC 27626-0535
Please also remember to submit a copy of this form along with the complete :animal Waste
Management Plan to the local Soil and Water Conservation District Office and to keep a copy
in your files with your Animal Waste Management Plan.
.august 1, I997 6

Producer: A., Pi Fa -'I I T:.- - cc. / �o ..ah a .,.a�C FV,r
Location: 33`\ cc tI-o*—\ 4 4
0-,v,e1ks, r1 G
Telephone:C.Rml 63 -a -'-r-1y Lf
Type Operation: - F, ; s 1,
Number of Animals: I a,X4C)
{Design Capacity}
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface and/or groundwater. The plant nutrients in the animal waste should
be used to reduce the amount of commercial fertilizer required for the crops in the fields
where the waste is to be applied. This waste utilization plan uses nitrogen as the limiting
nutrient. Waste should be analyzed before each application cycle. Annual soil tests are
strongly encouraged so that all plant nutrients can be balanced for realistic yields of the
crop to be grown.
Several factors are important in implementing your waste utilization plan in order to
raw * e the fertikervalue of the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the needs of the crop to be
=own and the nutrient content ofthe waste. Do not apply more nitrogen than the crop
can utilize. Soil types are important as they have digerent infiltration rates, leaching
ti potenals. cation exchange capacities, and available water holding capacities. Normally
wa-,-shall not be applied to land eroding at greater than tons per acre per year. With
special precautions, waste may be applied to land eroding at up to 10 tons per acre per
year. Do not apply waste on saturated soils, when it is raining, or when the surface is
frozeu. Either of these conditions may result in runoff to surface waters which is not
allowed under DEM regulations. Wind conditions should also be considered to avoid drift
and downwind odor problems. To maximize the value of nutrients for crop production
and to reduce the potential for pollution, the waste should be applied to a growing crop or
applied to bare ground not more than 30 days prior to planting. injecting the waste or
dlskiug will conserve nutrients and reduce odor problems_
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. Acreage requirements should be based on the waste analysis
report from your waste management facility. Attached you will find information on
proper sampling techniques, preparation, and transfer of waste samples to the lab for
analysis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A
NCAC 2H.0217 adopted by the Environmental Management Commission.

Amount of Waste Produced Per Year allons tans etc.
I 0d animals Xi,,L{7� waste/anitnal/year =� � �fiwaste/year.
Amount of Plant Available Nitrogen (PAN) Produced Per Year
1),a±O annals X a.3 lbs. PAN/animallyear = 2Y452.Ibs. PAN/year. (PAN from N. C. Tech.
Guide Std. 633)
Applying the above amount of waste is a big job. You should plan time and have
appropriate equipment to apply the waste in a timely mann er.
The following acreage wdl be needed for waste application based on the crop to be grown
and surface application:
Table 1: ACRES OWNED BY PRODUCER
Tract Field Sod Crop Lbs. N Acres Lbs. N Month of
rr No. Tvne Per Ac_ * Utilized Ant)Hcation
COT.
l
o -CAB
Borne 6
u1a.Ca 1.5.1
'-1Q fo L+ -Ocf.
CL I Te .+.
I a
e,,„MaaCb
O d 1 6 d .5
r 5CX5 -o ±.
C l y►f. ✓
�"'
I � rw :n
.S' 16 p. �
� c�o4
I r. �
I
I
�
f
I
I
* This N is from animal waste only. Ijnutrients from other sources such as corrvnercW
ferr :er are applied, they trwst be accounted far. N must be based on realistic yield
expectation.
NOTE: The applicator is cautioned that P and K maybe over applied while meeting the N
requ irementr, Beginning in 1996 the Coastal Zone Management Act will require farmers in
sonu eastern counties ofNorth Carolina to have a nutrient management plan that addresses
all nutrients. This plan only addresses Nitrogen.
2

z:s_�.�.....ie:�;i:S�.:as:;•.:�:i u:u:r�,:,...��a::c r::;�..�.:.....,....�
Table Z: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowner must be attached)
(Required only if operator does not own
adequate land (see Required Specificarion 2])
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
!�e Per Ac.�.
��-VAWAVMA ����
■ter
* See footnote jar Table 1.
Totals from above Tables
Acres Lbs. N
Utilized
Table I
Table 2
Total l a C'. 3 I a s 53 (o
Amount of Produced 15 a
Surplus o6iw3
NOTE- The Waste Utilization Plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient rich and will
require precautionary measures to prevent over application oy'nutrients or other
elements.

20-
Lip x'
See attached map showing the fields to be used for the utilization of wasre water.
Application of Waste by Irrigation
Field Soil Type Crop Application Application
No. Rate (In/I1r) Amount (In.)
la-
rMH A C,
,S-I.o
0
T--S TABL'E LS NOT NEmID T WAST LS NOT BEEndG AP MD BY =IaATION. HOWEVER A SOaAR YABL WUL
BE -N=- - ED FOR DRY Lr= OR SLURRY.
Your facility is designed for�Odays of temp orary storage and the temporary storage
must be removed on the average of once every C MONTHS. In no instance should
the volume of waste being stored in your stricture exceed Elevation lrsr,&l o .
30
Call the local Natural Resources Conservation Service (formerly Soil Conser.ation
Service) or Soil and Water Conservation District office after you receive the waste
analysis report for assistance in determining the amount per acre to apply and the proper
application rate prior to applying the waste.
4

y3Yn5� rz
W.
L
2.w�......:......:......»........s,w..:r:,........'e<:.::•..«.i`.ttci,::...:::::,,r..snr'T: 3::.i,...S..»ism•-aiw.......::<:....».....wc.� - k
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff drift, manmade
conveyances, direct application, or direct discharge during operation or land
application. Any discharge of waste which reaches surface water is prohibited
2. There must be documentation in the design folder that the producer either owns or has
an agreement for use of adequate land on which to properly apply the waste. If the
producer does not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within: a reasonable
proximity, allowing himlher the use of the land for waste application. It is the
responsibility of the owner of the facility to secure an update of the Waste UttEwdon
Plan when there is a change in the operation, increase in the number of animals,
method of utilization, or available land.
:3 . Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic
crop yields based on soil type, available moisture, historical data, climatic conditions,
and level of management. unless there are regulations that restrict the rate of
application for other nutrients.
4. Animal waste shall be applied to had eroding less than 5 tons per acre per year.
Waste may be applied to land that is eroding at 5 or more tons, but less than 10 tons
per acre per year providing grass filter strips are installed where runoff leaves the field.
(See FOTG Standard 393 - Filter Strip).
5. Odors can be reduced by injecting the waste or dishing after waste application. Waste
should not be applied when there is danger ofdrift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil
incorporated on conventionally tilled cropland. When applied to conservation tMed
crops or grassland, the waste may be broadcast provided the application does not
occur during a season prone to floodin (See "Weather and Climate in North
Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
runoff does not occur offsite or to surface waters and in a method which does not
cause drift from the site during application- No ponding, should occur in order to
control -odor or flies.
8. Amimal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.

.... ...,........ '.,.,...2......v. .......w,.+..:ct::.%,��,ar.'Wi»,..rnw.:.=..` c.S ':i......... 'iti..ii<G.{ii:'aY'...�2:....,...�.ci:t:w...............:....,K. ;�4.v.
REQUIRED SPECIFICATIONS
(continued)
9. Animml waste shall be applied on actively growing crops in such a manner that the
crop is not covered with waste to a depth that would inlubit growth. The potential for
salt damage from animal waste should also be considered-
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste nutrient loading rates on these soils should
be held to a minimum and a suitable winter cover crop planted to take up released.
nutrients. Waste shall not be applied more than 30 days prior to planting of the crop
or forages breaking dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the
following: The outer perimeter of the Iand area onto which waste is applied from a
lagoon that is a component of a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other than as inigation
ditch or canal. Animal waste other than swine waste from facilities shed on or after
October 1, 1995), shall not be applied closer than 25 feet to perennial waters. (See
Standazd 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and public right-of-
ways.
15. Animal waste shall not be discharged into surface waters, drainageways, or wetlands
by a discharge or by over -spraying. Animal waste may be applied to prior converted
wetlands provided they have been approved as a land application site by a "technical
sp ecialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc.,
shall not be discharged into the animal waste management system.
6

REQUIRED SPECIFICATIONS
(continued)
13. If animal production at the facility is to be suspended or terminated, the owner is
responsible £or obtaining and implementing a "closure plan" which will elhTfMate the
possbility of an legal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks, and spills. A regular maintenance checklist should
be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops for
direct human consumption. However, if animal waste is used on crops for direct
human consumption it should only be applied preplant with no further applications of
animal waste during the crop season.
21. IEghly visible markers shall be installed to mark the top and bottom elevations of the
temaorary storage (pumping volume) of all waste treatment lagoons. P=ing shall
be managed to maintain the liquid level between the markers. A mark:: wM be
required to mark the maximum storage volume for waste storage ponds.
22. Waste shall be tested within 69 days ofutilization and soil shall be tested at least
manually at crop sites where waste products are applied. Nitrogen shall be the rate -
determining element. Zmc and copper levels in the soils shall be monaored and
alternative crop sites shall be used when these metals approach excessive le•/e'.s. pH
shall be adjusted for optimum crop production and maintained. Soli and waste
analysis records shall be kept for five years. Poultry dry waste application records
shall be maintained for three (3) years. Waste application records for all other waste
shall be maintained for five (5) years.
2:3. Dead animals willbe disposed of in a manner that meets North Carol.aza regulations.

WAS UTILIZATION PLAN AGREEMENT
Mame of Farm: CC. f 7o m a h r. t j� - -
Owner/Marzager Agreement
I (we) understand and wM follow and implement the specification and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. I (we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new facilities will require anew
certification to be submitted to the Division of Environment Management (DEA) before
the new animals are stocked. I (we) also understand that there must be no discharge of
animal waste from this system to surface wasters of the state from a storm event less
severe than the 25-year, 24-hour storm. The approved plan will be filed on -site at the
farm office and at the once of the local Sod and Water Conservation District and WI[ be
available for review by DEM upon request.
Name of Facility Owner. A, r PL4 a nF 1 o f s
(Plzrsr �rintJ
Signature: Date:
Name of ager(lf daferent from owner):
Si nature: Date:
Name of Technical Specialist; (Please print) ra, ar
i:l . s
Address (E
Sianarur

I
XN.

C,01
,
Soils Legend
�, - fir:;-1ck a,•,a � M.a�a,+� ,� Q:.4-�
[�. Leal- La_or.,-4..0-..•�
1�
AbC, L_ � .
MURPHY FAMILY FARMS
Rose Hill, North Carolina
Farmfrract Name
Location SR. 1151T &npS n GQ_ Date �jyr
Scale / ": 1.5 to ' Acres
Drawn by:
Features drawn from: ,�-

CC/ % e m
System Calibration
Information presented in manufacturer's charts are based on average operation
conditions with relatively new equipment. Discharge rates and application rates
change over time as equipment gets older and components wear. In particular,
pump wear tends to reduce operating pressure and flow. With continued use,
nozzle wear, results in an increase in the nozzle opening which will increase the
discharge rate while decreasing the wetted diameter.
You should be aware that operating the system differently than assumed irr the
design will after the application rate, diameter of coverage, and subsequently the
application uniformity. For example, operating the- system with excessive pressure
results in smaller droplets, greater potential for drift-, and- accelerates wear afthe-
sprinkler nozzle. Clogging of nozzles can result in pressure increase-. Plugged-
intakes or crystallization of mainlines will reduce operating pressure. Operating
below design pressure greatly reduces the coverage diameter and application
uniformity.
For the above reason, you should calibrate your equipment on a regular basis to r
ensure proper application rates and uniformity. Calibration at least once every
three years is recommended. Calibration involves collecting and measuring flow at
several locations in the application area. Any number of containers can be used to
collect flow and determine the application rate. Rain gauges work best because
they already have a graduated scale from which to read the application amount
without having to perform additional calculations. However, pans, plastic buckets,
jars, or anything with a uniform opening and cross-section can be used_ provided
the liquid collected can be easily transferred to a scaled container for measuring.
For stationary sprinklers, collection containers. should be located randomly
throughouT the application area at several distances from sprinklers. For traveling
guns, sprinklers should be located along a transect perpendicular to the direction
of pull. Set out collection containers 25 feet apart along the transect on both
sides of the gun can:. You should compute the average application rate for all
nonuniformity of the application. On a windless day, variation between containers
of more than 30 percent is cause for concern. You should contacr your irrigation
dealer or technical specialist for assistance.
'Reprinred for Certification Training for Operations of Animal Waste Management Systems Manual

OPERATION & ANCE PLAN
Proper lagoon liquid manageme+rt should be a year-round priority. It is especially
important to manage levels so that you do not have problems during extended rainy and
wetpedods.
M23dmum storage capacity should be available in the lagoon for periods when the
receiving is dormant (such as wintertime for berraudap -ass) or when there are
ended many sells such as the thund---'storm season in the summerrime.. This means
.that at the Furst signs of plant growth in the lat= wintei/eariy spring, irrigation ac.rormng to
a fame waste management platy should be done whe.-ever the- land is dry enough to
receive lagoon liquid. This will make storage space available in the lagoon for future wet
periods_ In the lacy summer/eariy fall the lagoon should be pumped down to the low
marker (see Figure 2-1) to allow for winter storage- Every effort should be made to
mabtrain the lagoon close to the minimum liquid level as -long as the weather and wash
utilimriorr plait will allow it:.
Waiting until the lagoon has reached its maximum storage capacity before starting to
irrigate does not Ieave room for storing excess water during e-�tended wet periods. _
Overflow lam the lagoon for any reason except a 25-year, 24--hour storm is a violzdcm or
s= law and subject to penalty action.
The routine 1mG:nteaance of a lagoon involves the following:
M--=tenancy of a veae='ve cove. for the dam.
F Pscue or common oe.,mudag ass are the most common vegetative
covers. The vege=aon should be fe_-dli:zed each v=, if -needed, to
Amin a vigorous stand. The amount of fe_. 117— applied should be
based on a soils trstr but in the event thaz it is not _practical to obtain
a soils test each year, the lagoon embanmment and surrounding areas
saouid be ferzili�— with 800 pounds per acre of 10-10-10, or
equivalent.
Brush and t= on the embankment must be controlled. This may be
done by mowing, s ving, grazing, chopping, or a combination of
these uz-acticrs. Tris should be done at least once a year and
nossioly twice in years that weather conditions are favorable for
heavy vegetative growth.
NOTE: If vegemdon is controlled by straying, the herbicide must not be allowed to eater
the lagoon water Such chemicals could harm the bact..ia in the lagoon that are
the waste_
Nfaintenan= insperions of the entire Iagoon should be made during the initial filling of
the lagoon and at Ieast monthly and aft:= major rainfall and storm events. Items to be-
checked should include, as a minimum, the following:
Waste Inlet Pipes, Recyciing Pipes, and Overflow Pipes ---look for.
I_ separation of joints
2- cra- or breaks
3. accumulation of salts or minerals.
4. overall condition of pipes

Lagoon surface----Iook for:
1. undesirable vegetative gxowth
2. floating or lodged debris
Embankment —look for.
1. settlement, cracking, or -jug" holes
2. side slope stability —slumps or bulges
3. wet or damp areas on the back slope
4. erosion due to lack of vegetation or as a result of wave action
5. rodent damage
Larger lagoons may be subject to liner damage due to wave action caused by strong
winds. These waves can erode the lagoon sidewalls, thereby weakening the lagoon data.
A good stand of vegetation will reduce the potential damage caused by wave action_ If
wave action causes serious damage to a lagoon sidewall, baffles irr the.lagoon- may be
used to reduce the wave impacts.
Any of these features could lead to erosion and weakening of the dam: If your lagoon has
any of then: futures, you should call an appropriate expert familiar with design and
construction of waste lagoons. You may need to provide a temporary -fix if there is a threat
of a waste discharge. However , a permanent solution should be reviewed by the
technical expert. Any digging into a lagoon dam with heavy equipment is a serious
undertaking with .notentially serious consequences and should not be conducted unless
recommended by an appropriate twhnical expert.
Transfer Pumps ---check for proper operation of:
1. recyclin' pumps
2. irrigation pumps
Check for leaks, loose fittings, and oveall pump operation. An unusually loud or grinding
noise, or a large amount of vibradon, may indicate that the pump is in need or repair or
replacement.
NOTE: Pumping systems should be inspected and operated.f=uently enough so that you_
are not completely "surprised" by equipment failure. You shoufd perform your -pumping
system main=ance at a time when your lagoon is at its low level. This will allow some
safety time should major repairs be required. Having anearly full lagoon is notthe time
to think about switching, repairing , or borrowing purmas. Probably, if your -lagoon is full,
yourneighborss lagoon is full also. You should considir mai.ntniningan inventory of spare
parts or pumps.
Surface water diversion features are designed to carry all surface
drainage waters (such as rainfall runoff, roof drainage, gutter outlets,
and parking lot runoff) away from your lagoon and other waste
treatment or storage structures. The only water that should be
coming from your -lagoon is that which comes from your -flushing
(washing) system pipes and the rainfall that hits the lagoon, directly.
You should inspect your diversion system for the following:
1. adequate vegetation
2. diversion capacity
3. ridge berm hieight

Identified tmoblems should be corrected promptly. It is advisable to inspect your system
during or immediately following a heavy rain. If technical assistance is needed to
determine proper solutions, consult with appropriate experts.
You should record the level of the lagoon just prior to when rain is predicted, and then
record the level again 4 to 6 hours afar the rain (assumes these is no pumping). This will
give you an idea of how much your lagoon level will rise with a crrrain rainfall amount
(you must also be recording your rainfall for this to worm). Knowing this should help in
planning irrigation applications and storage. If your lagoon rises excessively, you may
have an inflow problem from a surface water diversion or there may be seepage into the
lagoon from the surrounding land.
Lagoon Operation
Startup:
1. Immediately after construction establish a complete sod cover on bare soil
surfaces to avoid erosion.
2. Fill new Iagoon design treatment volume at least half full of water before
waste loading begins, taidng care not to erode lining or bank slopes.
3. Drainni= into the lagoon should have a flexible nine extender on the
end of the pine to disc:.arge near the bottom of the lagoon during initial
filling or another means of slowing the incoming water to avoid erosion of
the lining.
4: When possible, be;in loading new lagoons in the spring to maximize
bacterial establishment (due to warmer weather).
5. It is recommended that a new lagoon be s=ded with sludge from a healthy
working swine la -croon in the amount of 0.25 percent of the full.iagoon
liquid volume. This seeding should occour at I=st two weeks priorto the
addition of wastewater.
6. Maintain a periodic check on the lagoon liquid pH. If the pH falls below
7.0, add agricultural lime at the rate of I pound per 1000 cubic fee.* of
lagoon liquid volume until the pH rises above 7.0. Optimum lagoon liquid
pH is between 7.5 and 8.0.
7. A dark color, lack of bubbling, and excessive odor signals inadequate
biological activity. Consultation with a technical specialist is recommended
if these conditions occur for prolonged periods, especially during the warm
season.
Loading:
The more frequently and regulariv that wastewate. is added to a lagoon, the better the
lagoon will function. Flush systems that wash waste into the lagoon several times daily are
optimum for treatment. Pit recharge systems, in which one or more buildings are drained
and recharged each day, also work weft.

Practice water conservation —minimize building water usage and
spillage from leaking waterers, broken pipes and washdown through
proper maintenance and water conservation.
Minimize feed wastage and spillage by keeping fevers adjusted. This
will reduce the amount of solids entering the lagoon
an2geme=
Maintain lagoon: liquid level between the permanent storage level and
the full temporary storage level.
Place visible markers or stakes on the lagoon bank to show the
minimum liquid level and the maximum liquid lever (Figure 2-1).
Start irrigating at the earliest possible daze in the spring based on
nutrient requirements and soil moisture so that 'temporary storage
will be maximized for the summer thunderstorm season. Similarly,
irrigate in the late summer/early fall to provide maximum lagoon
storage for the winter.
The lagoon liquid level should never be close. than 1 foot to the lowest
point of the dare or embankment.
Do not pump the lagoon liquid level lower that the permanent storage
level unless you are removing sludge.
Locate float pump intakes approximately IS inches underneath the liquid
surface and as far away from the drainpipe inlets as possible.
Prevent additions of bedding materials, long-stemmed forage orvegetat<on,
molded feed, plastic syringes, or other foreign materials into the lagoon.
Frequently remove solids from catch basins at end of confinement houses or
wherever they are installed.
Maintain strict vegemtion, rodent, and varmint control near lagoon edges.
Do not allow tr= or large bushes to grow on lagoon dam or embankm=t
Remove sludge from the lagoon either when the sludge storage capacity is
full or before it tills 50 percent of the permanent storage volume.
If animal production is to be terminated, the owner is responsible for
obtaining and implementing a closure plan to eliminate the possibility of a.
pollutant discharge.
Sludge Removal:
Rate of lagoon sludge buildup can be reduced by:

proper lagoon sizing,
mechanical solids seaaration of flushed waste,
araviry settling of flushed, waste solids in an appropriately designed basin, or
minimizing feed wastage and spillagge.
Lagoon sludge that is removed annually rather than stored long term will:
have more nutrients,
have more odor, and
require more land to properly use the nutrients.
Removal =hnicues:
Hire a custom applicator.
Mix the sludge and lagoon liquid with a chopper -agitator impeller
pump through Iarge-bore sprinkler irrigation system onto nearby cropland;
and soil incomoram.
Dewater the utmer part of Iagoon by irrigation Onto nearby cropland or
forageland; mix remaining sludge; Pump into licuid sludge av licatar; haul
and spread onto cropland or forageiand; and soil incorporate.
Dewater the ut;t}e. Dart of lagoon by irrigation onto nearby cropland or
;orageland; drage sludge from lagoon with ddiagiine or siudge barge; germ
an area beside lagoon to receive the sludge so that liquids can drift bark
into lagoon; allow sludge to dewater; haul and spread with manure soreaaer
onto cropland or forageland; and soil incorporate.
Regardless of die method, you must have the sludge material analyzed for waste
constituents just as you would your lagoon water. The siudge will. contain duf=t
nutrient and metal values from the liquid. The application of the siudge to fields will. be
Limited by these nutrients as well as any previous waste aptslic arions to that field and crop
requirement Waste application rates will be discussed in detail in Chapter 3.
When removing sludge, you must also pay attention to the liner to prevent damage. Cose
attention by the pumper or drag -line operator will ensure that the lagoon liner remains
intact_ If you see soli material or the synthetic liner material being disturbed, you should
stop the a.ctiviry immediately and not resume until you are sure that the sludge can be
removed without liner injury. If the liner is damaged it must be repaired as soon as
possible.
Sludge removed from the lagoon has a much higher phosphorus and -heavy metal content
than liquid_ Be`ause of this it should probably be appiied to land with Iow phosphorus
and mewl levels, as indicated by a soil test, and inco- crated to reduce the chance of
erosion. Note that if the sludge is applied to fields with very high soil -test phosphores, it
should be applied only at rates equal to the crop removal of Dhosphonis. As wiih othe^
wastes, always have your lagoon sludge analyzed for its nutrient value.
The applic�on of sludge will i.ncre: se the amount of odor at tht waste application site_
Exrra precaurion should be used to observe the wind direction and other conditions which
could increase the concern of neighbors.

Possible Causes of Lagoon Failure
Lagoon failures result in the unplanned discharge of wasmwater from the structure. Types
of failures include leakage through the bottom or sides, oven ppi.ng, and breach of the
dam. Assuming proper design and construction, the owner has the responsibility for
ensuring sauctvre safety. Items which may lead to lagoon failures include:
Modification of the lagoon structure --an ==ple is the placement of a- pipe
in the dam without proper design and construction. (Consult. an expert in
lagoon design before placing any pipes in dams.)
Lagoon liquid levels ---high levels.are a safety risk.
Failure to inspect and maintain the dam.
Excess surface water flowing into the lagoon.
Laver integrity —protest from inlet -pipe scouring, damage during sludge
removal, or runrure from lowering lagoon liquid level below groundwater
table.
NOTE: JJ lagoon water is allowed to overtop the dam, the moving water, will soon Calls
gullies to form in the dam. Once this damage starts, it can quicklycause a Iarge discharge
of wastewa.- and possible dam failure.

EMERGENCY ACTION PLAN
PHONE NUMBERS
DIVISION OF WATER QUALITY (DW(a) lo)�i%(.
EMERGENCY MANAGEMNEi SERVICES (EMS) /v - 1
SOIL AND WATER CONSERVATION DISTRICT (SWCD) 5�a-7qb 3
NATURAL RESOURCES CONSERVATION SERVICE (NRCS) fro a_-7q�3
COOPERATIVE EXTERSION SERVICE (CES)
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing or running off site. You should not wait until wastes reach surface waters
or leave you property to consider that you have a problem. You should make every
effort to ensure that this does not happen. This plan should be posted in an accessible
location for all employees at the facility. The following are some action items you should
take.
1'. Stop the release of wastes. Depending on the situation, this may ore may not be
possible. Suggested responses to some possible problems are listed belwo.
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no sul .ace water is entering lagoon.
E. Runofffrom waste application field -actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste ,.o reduce runoff.
d. Evaluate and eliminate the reason(s) that cause the runoff.
e. _valuate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
D. Leakage from flush systems, houses, solid separators=action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed
to flowing leaks -possible action:
a. Dig a small sump or ditch from the embankmerrrto catch all
seepage, put in a submersible pump, and pump back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls -and lagoon -
bottom as soon as possible.
Z'

2. Assess the extent of the spill and note any obvious damages.
a. Did the waste. reach any surface waters?
.b. Approximately how much was released and for what duration?
C. Any damage notes, such as employee injury, fish !tills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours call your DWQ regional office; Phone - -. After
hours:, emergency number: 919-733-3942. Your phone call should include: your
name, facility number, telephone number, the details of the incident from item 2
above, ,he exact location of the facility, the location or direction of movement of
the spill, weather and wind conditions. The corrective measures that have been
under taken, and the seriousness of the sitution.
b. If soil! leaves property or enters surface waters, call local EMS phone number.
c.• Instruc- EMS to contact local Helath Department.
d. Contac. CE-s, phone number - , local SWCD office phone number - -, and local
NRCS office for advice/technical assistance phone number - -.
4. If none o; the above works call 911 or the Sheriff's Department and explain you
problem to them and ask the person to contact the proper agencies for you.
5. Conzac- the contractor of your choice to begin repair or problem to minimize off -
site damaae.
IA
a. Con LI acmrs Name.
b. Contractors Address
c. Contractors Phone:
6. Contact the technical specialist who certified the lagoon (NRCS, Consuiting
Engineer, etc.)
a. Name:
b. Phone: _Cc tto Sq-7-m -
7. Implement procedures as advised by DWQ and technical assistance agencies to
recc:ify the damage, repair the system, and reassess the waste managment plan to
keep problems with release of wastes from happening again.
tj

Source
INSECT CONTROL CHECKLIST FOR ANIMAL OPERATIONS
Cause
BMP's to Minimize Odor
(Liquid Systems)
Flush Gutters Accumulation of solids { Flush system is designed and operated
sufficiently to remove accumulated
- s``oilds from gutters as designed.
( li"ve bridging of accumulated solids at
discharge
Lagoons and Pits Crusted Solids 57mllntain lagoons, se[tfing basins and
pits where pest breeding is apparent to
minimize the crusting of solids to a depth
of no more than 6-8 inches over more than
% of surface.
Site Specific Practices
Excessive Vegetative Decaying vegetation (} Maintain vegetative control along banks of
Growth lagoons and other impoundments to prevent
accumulation of decaying vegetative marter
along water's edge on impoundments perimeter.
(Dry Systems)
Feeders Food Spillage (} Design, operate ana maintainfeeo systems (e.g.,
bunkers and troughs) to minimize the accumuiation
of decaying wastage.
(} Clean uo soiflage on a routine basis (e.g. 7-10 day
interval during summer, 15-30 day interval during winter).
Feed Storage Accumulations of feed residues ( ) Reduce moisture accumulation within and around
immediate perimeter of feed storage areas by
insuring arainage away from site end/or providing
adequate containment fe.g., covered bin for
brewer's grain and similar high moisture grain
products).
(i Inspect for and remove or break uo accumulated
solids in filter strips around food storage as needed.
Animal Holding Arwm Accumulations of animal wastes ( ) Eliminate low area that trap moisture along terx-ss
and feed wastage and other locations where waste accumulates and
and disturbance by animals is minimal.
(} Maintain fence rows and filter strips around animal
holding areas to minimize accumulations of wanes
G.e. inspect for and remove or break up accumulated
solids as needed).
,&41C•-November 11, 1995

pry Manure Handling Accumulations of animal westoa Remove spillage an a routine basis Ie,g. 7-10 dry
Systems interval during summer, 15-30 days interval during
winter] where manure is loaded for lend appGarpon
or disposal.
(I Provide for adequate drainage around manure suckpies_
(y Irt peer for and remove or break up accumulated wasters
in filter stripes around stockpiles and manure handfing
areas as needed.
The issues checked ( ) pertain to this operation. The landownerfintegrator agrees to use sound judgment in applying
insect control measures as practical.
I certify the aforernerrrioned insect control Besr Management- Practices have been reviewed with me.
(Landowner Signature)
For more information ccntac -the Cooperative Extension Service. Department of Entomology. Box 7613,.North Cam5na Simla University, Raleigh, NC
?7695-7613.
AMIC--November 11. 1996

SWINE FARM WASTE MANAGEIME:NT ODOR CONTROL CHECKUSi
Source Cause 8MP's to Minimize Odor Site Specific Practices
Farmstead Swine production kfVegatavve or wooded buffers;
ecommended best management
�eetiCas;
{ j Gaud judgment and common sense
Animal body surfaces Dirty manure -covered arimals ( i'Dry floors
Floor surfaces Wet manure -covered floors lotted floors:
S, Waterers located over slotted floors;
(. �. ders at high and of solid floors;
( 'crape manure buildup from floors;
( } Underfloor ventilation for drying
Manure collection pits Urine ( requent manure removal by flush pit
recharge.orscrape
Nrital micorbial decomposition () Underfloor ventilation
Ventilation exhaust fans Volatile gases; { an ncenanca;
Dust ( reient air movement
Indoor Surfaces OUST { asndown between groups of animals
( ) Feed additives;
{) Feeder covers;
O Feed delivery downspout extenders to
feeder covers
Flush tanks Agitation of recycled lagoon (} Flusn tank covers
liquid whiles tanks afe nlling {) Extend fill lines to near bottom of
ranks with anti -siphon vents
Flush alleys Agitation during wastewater ( ) Underfloor flush with unoeMocr
conveyanance ventilation
Pit recharge points Agitation of recycled lagoon` ( ) Extend rachard lines to near bottom of
liquid while pits are filling pits with anti -siphon vents
Lift stations Agitation during sump tank filling () Sumo tank covers
and drawdown
Outside drain collection Agitation during wastewater O Box covers
or junction boxes conveyanco
End of drainpipes at lagoon Agitation during wastewater ( ) Extend ciscnarga point of pipes
underneath lagoon liquid level
Lagoon surfaces Volatile gas emissions ( 7'.oar lagoon Hcuid capacity
Biological mixing (T Correcr lagoon startup procedures
Agitation { }/' mum surface area -to -volume ratio
(.I Minimum agitation wnen pumping
( ) Mechanical aeration
o () Proven biological additives
Irrigation sprinkler noes Nign pressure agitation ( gate on dry days with little or no wind
Wind draft ( fdiirwmum recommended operation pressure
(I Pvrrm intaKe near lagoon liquid surface
( ) Pump from second -stage lagoon
+MOC—November 11. 1996

Storage tank or basin Partial microbial decomposition O Bottom or nidlevel loading
surface Mining while filling () Tank covens
Agitation when emptying {) Benin surface mats of solids
() Proven biologicai additives or oxidants
Settling basin surface Partial micobial decomposition ( ) Extend drainpipe outlets underneath liquid
MWng while filling level
Agitation when emptying (} Remove settled solids regularly
Manure, slurry or sludge Agitation when spteeding ( ) Soil injection of slung/sludges
Spreader outlets Voiatile gas emissions ( ) Wash residual manure from spreader after use
( ) Proven biological additives or oxidants
Uncovered manure, slurry Volatile gas emissions whiie drying () Soil infection of slurry/sludges
or sludge on field surfaces () Soil incorporation within 48 hours
() Spread in thin uniform layers for rapid drying
() Proven biological additives or oxidants
Dead animals
Carcass decomposition
{ Proper disposition of carcasses
Dead animal disposal
Carcass decomposition
( ) Complete covering of carcasses in burial pits
pits
( ) Proper locationlconstruction of disposal pits
Incinerators
Incomplete combustion
( ) Secondary static burners
Standing water around
Improper drainage
{ kdrace and landscape suon that water drains
facilities
Microbial decomposition of
away from facilities
organic matter
Manure tracked onto public
Poony maintained access roads
( arm access road maintenance
roads from farm access
Additional Information: Available From:
Swine Manure Management: 0200 Rule/SMP Packet NCSUtisunty Extension Canter
Swine Production Fart Potential Odor Sources and Remedies, ESAE Fact Shoat
NCSU-aAE
Swine Production FacHiry Manure Management: PitRachsrge-Lagoon Treatment: EBAE 123-88
NCSU-aAE
Swine Production Facility Manure Management: Underfloor Huse -Lagoon Treatment; -ESAE 1 ZS-28
NCSU-3AE
Lagoon Desig and Management for Livestock Manure Treatment and Storage; ESAE 103-33
NCSU-aAE
-:aiibration of Manure and Wastewater Application Equipmerm EBAE Fact Sheet
NCSU-aAE
Controlling Odors from Swine Buildings; PIN-33
NCSU-Swine Extension
Environmental Assurane Program: NPPC Manual
NC Pork Produces Assoc
Options for Managing Odor, a report from the Swine Odor Task Force
NCSU Agri Communications
Nuisance Concerns in Animal Manure Management Odors and Flies: PRO107, 1995 Conference Proceedings
Aerida Cooperative Extension
i he issues checked { } pertain to this operation. The landowner/integrator agrees to use sound judgment in applying
odor control measures as practical.
certify the aforemerstioned odor control Best Managment Practices have been reviewed with me.
( d ner Signature
MOC--!November 11. 1996

r
MORTALITY MANAGEMENT METHODS
{check which method(s) are being implemented)
{ } Burial three feet beneath the surface of the ground within 24 hours
after knowledge of -the death. The burial be at least 300 feet from
any flowing steam or public body of water.
{ Randering at a rendering plant licensed under G. S. 106-168.7
( ) Complete incineration
{ } In the case of dead poultry only, placing in a disposal pit of a size and
design approved by the Department of Agriculture.
{ } Any method which in the professional opinion of the State
Veterinarian would make possible the salvage of part of a dead
animal's value without endangering hurnan or animal health. (WrirLen
approval of the State Veterinarian must be attached)

V .1
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P. E., Director
Division of Water Quality
April 9, 2003
Murphy Farms
CC/Tomahawk Farm
PO Box 759
Rose Hill NC 28448
Subject: Certificate of Coverage No. NCA282030
CC/Tomahawk Farm
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
Dear Murphy Farms:
On March 14, 2003, the North Carolina Division of Water Quality (Division) issued an NPDES General
Permit for swine facilities. The General Permit was issued to enable swine facilities in North Carolina to
obtain coverage under a single permit that addresses both State and Federal requirements.
In accordance with your application received on February 13, 2003, we are hereby forwarding to you this
Certificate of Coverage (COC) issued to Murphy Farms, authorizing the operation of the subject animal
waste collection, treatment, storage and land application system in accordance with NPDES General
Permit NCA200000. The issuance of this COC supercedes and terminates your COC Number
AWS820030 to operate under State Non -Discharge Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the CC/Tomahawk Farm, located in Sampson County, with an animal capacity of
no greater than an annual average of 42240 Feeder to Finish swine and the application to land as
specified in the facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to
Wean or Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are
unneccessary, they may be replaced by an equivalent number of sows. Any of the sows may be replaced
by gilts at a rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until July 1, 2007. Pursuant to this COC, you are
authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed General Permit. Since this is a new joint State and
Federal general permit it contains many new requirements in addition to most of the conditions contained
in the current State. general permit. Enclosed for your convenience is a package containing the new and
revised forms used for record keeping and reporting. Please pay careful attention to the record keeping
and monitoring conditions in this permit. The Devices to Automatically Stop Irrigation_Events Form
must be returned to the Division of Water Quality no later _ than 120 days following receipt of the
Certificate of Coverage. The Animal Facility Annual Certification Form must be completed and returned
to the Division of Water Qualityby no later than March 1st of each ,dear.
.. i A
Non -Discharge Permitting Unit Internet http://h2a.enr,statg.no.us/ndpu
1617 Mall Service Center, Raleigh, NC 27699-1617 Telephone [phone] Fax [phone]
Customer Service Center Telephone [phone]B
An Equal Opportunity Action Employer 50% recycied/10% post -consumer paper

, 1.
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 2H .0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100 foot separation
shall be maintained between water supply wells and any lagoon or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C, the Clean Water Act and 40 CFR 122.41 including civil penalties, criminal
penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual NPDES Permit by contacting the staff member listed below for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact J R Joshi at [phone] ext. 363.
Sincerely,
for Alan W. Klimek, P.E.
Enclosures (General Permit NCA200000, Record Keeping and Reporting Package)
cc: (Certificate of Coverage only for all cc's)
Sampson County Health Department
Fayetteville Regional Office, Water Quality Section
Sampson County Soil and Water Conservation District
Permit File NCA282030
Permit File AWS820030
NDPU Files

CC Tomahawk Farm
Spray Fields
Scale: 1'=500'
Lagoon and
Hog
� I
Houses

r�cxrr�c

State of North Carolina
Department of Environment,
Health and Natural Resources ` •
Fayetteville Regional Office
James B. Hunt, Jr., Governor ±2ID E H N f� Jonathan B. Howes, Secretary
Andrew McCall, Regional Manager
DIVISION OF ENVIRONMENTAL MANAGEMENT
November 9, 1994
Mr. Calvin Hall, Manager
Murphy Family Farms
Route 1, Sox 95B
Harrells, NC 28444
SUBJECT: Compliance Inspection
Sampson County
Dear Mr. Hall:
On November 8, 1994, an inspection of your animal operation was performed
by the Fayetteville Regional Office (FRO). Please find enclosed a copy of our
Compliance inspection Report for your information. It is the opinion of this
office that this facility is in compliance with 15A NCAC 2H, Part .0217, and
that Animal Waste Management is being properly performed.
Should you have any questions regarding this matter, feel free to contact
me at [phone].
Sincerely,
Grady Tobaon
Environmental Engineer
Enclosure
cc: Facility Compliance Group
Gary Scalf
WachoAa Building, Site 714, Fayetteville, North Carolina 28301-5043 Telephone [phone] FAX 910-48"707
An Equal Opportunity Affirmative Action Employer 50%recycled/ 10% post -consumer paper

di
NORTH CAROLINA DEPARTMENT OF ENVIRONMENT, HEALTH S NATURAL RESOURCES
DIVISION OF ENVIRONMENTAL MANAGEMENT
Fayetteville Regional Office
Animal Operation Compliance Inspection Form
Calvin Hall, Manager
Tomahawk Farm
Murohv Family Farms 11/8194 TMK
Route 1, Box 95B
Harrells, NC 28444
All questions answered negatively will be discussed in sufficient detail in
the Comments Section to enable the deemed Permittee to perform the appropriate
corrections:
;�EE�TIQN_I
Animal Operation Type:
Horses, cattle, $wine, poultry, or sheep
SECTION II
1. Does the number and type of animal meet or exceed
the (.0217) criteria? [Cattle (100 head),
horses (75), swine (250), sheep (1,000), and
poultry (30,000 birds with liquid waste
system))
2. Does this facility meet criteria for
Animal Operation REGISTRATION?
3. Are animals confined fed or maintained
in this facility for a 12-month period?
4. Does this facility have a CERTIFIED,ANIMAL
WASTE MANAGEMENT „PLAN?
5. Does this facility maintain waste management
records (Volumes of manure, land applied,
spray irrigated on specific acreage with
specific cover crop)?
6. Does this facility meet the SCS minimum
setback criteria for neighboring houses,
wells, etc?
un
!IN
.moHee
l,
III�I

x
SECTION III
Field Site Manaaement
I. Is animal waste stockpiled or lagoon
construction within 100 ft. of a USGS
Map Blue Line Stream?
2. Is animal waste land applied or spray
irrigated within 25 ft. of a USGS Map
Blue Line Stream?
3. Does this facility have adequate acreage
on which to apply the waste?
4. Does the land application site have a
cover crop in accordance with the
C=TIFICATION PLANT
5. Is animal waste discharged into waters of
the state by man-made ditch, flushing system,
or -other similar man-made devices?
6. Does the animal waste management at this
farm adhere to Best Management Practices
(BMP) of the approved CERTIFICATION?
7. Does animal waste lagoon have sufficient
freeboard? How much? {Approximately 8f _}
8. Is the general condition of this CAFO facility,
including management and operation,
satisfactory?
SECTION IV
Qomments
Section II (4): This is a facility built prior to 1993, and the certified
plan will not be required until the end of 1997.
Section III (4 and 6): A certified plan is not required until 1997, but a
cover crop is established and is well managed and maintained.

4.
_ State of North Carolina
Department of Environment
and Natural Resources
Michael F. Easley, Governor
William G. Ross Jr., Secretary
Gregory J. Thorpe, Ph.D., Acting Director
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Murphy Farms
CC/Tomahawk Farm
PO Box 759
Rose Hill NC 28448
Dear Murphy Farms:
/ •
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
February 4, 2002
Subject: Notification for Wettable Acre Determination
Animal Waste Management System
CC/Tomahawk Farm
Facility Number 82-30
Sampson County
A letter dated January 15, 1999 was sent to advise you about concerns associated with Certified Animal
Waste Management Plans and the method by which the irrigated acres within the plans were calculated. Only
the acres that are wetted can be credited in the waste management plan as receiving waste application. Any
acreage within the plan that can not be reached by waste application equipment can not be used as part of your
plan.
An evaluation by Trent Allen on 2/11/99 was made to review the actual number of acres at your facility
that receive animal waste during land application. The evaluation of your facility has yielded one of the
following two results as indicated by the box marked with an "X".
Category 1:
❑ The evaluation of your facility could not be completed due to a lack of information. Please
contact your Technical Specialist to assist in providing Trent Allen the Necessary
information to potentially exempt your facility from undergoing a complete wettable acre
determination. Please submit this information to Trent Allen, at 225 Green Street, Suite
714, Fayetteville, NC 28301, within in 90 days of the receipt of this letter. If you have any
questions please contact Trent Allen at [phone]. If within 90 days you are unable
to provide Trent Allen with the Information you are automatically required to complete
a Wettable Acre Determination as described by Category 2 below, within 180 days
of receipt of this letter.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity AMrmative Action Employer 50% recycled/10%a post -consumer paper

6.
Notification for Wettable Acre Determination
Animal Waste Management System
Page 2
Category 2:
JK Your facility has been identified by the Department of Environment and Natural Resources
as a facility that may have overestimated the number of acres actually receiving animal
waste. Therefore, some or all of your fields may be exceeding the allowable loading rates
set in your Certified Animal Waste Management Plan.
In order to resolve this issue, please contact a designated Technical Specialist to have him
or her conduct a Wettable Acre Determination for your facility. The Technical Specialist must
be one that has been approved by the Soil and Water Conservation Commission to conduct
Wettable Acre Determinations. Many Technical Specialist with the N,C. Cooperative Extension
Service, the Soil and Water Conservation Districts, the Natural Resources Conservation
Service, and the Division of Soil and Water Conservation have received this special
designation. You may also contact a private Technical Specialist who has received this
designation, or a Professional Engineer.
All needed modifications to your Animal Waste Management System must be made and
the Wettable Acres Determination Certification must be returned to DWQ within the next
180 days. If the needed modifications are not made and if the form is not returned within the
required time, DWQ will be forced to take appropriate enforcement actions to bring this facility
into compliance. These actions may include civil penalty assessments, permit revocation,
and/or injunctive relief.
Once a Wettable Acre Determination has been completed, a copy of the attached Wettable
Acre Determination Certification must be submitted to the address listed on the form. Please
note that both the owner and the Technical Specialist must sign the certification. A copy of all
the Wettable Acre Determination documentation that applies to your Waste Utilization Plan
must be kept at your facility. DWQ and the Division of Soil & Water Conservation Staff will
review all documentation during their annual visit of your facility. An additional copy must by
kept on file at the local Soil & Water Conservation District Office. Please note that if you install
or modify your irrigation system, a designated Irrigation Specialist or a Professional Engineer
must also sign the Wettable Acre Determination Certification.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Sonya Avant of our
Central Office staff at [phone] ext. 571.
Sincerely,
cc: Fayetteville Regional Office
Sampson County Soil and Water Conservation District
Facility File
Murphy Family Farms

State of North Carolina
Department of Environment,
Health and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
MEMORANDUM
ED FE P4 F1
December 18, 1997
DEC 2 1 199/
TO: Fayetteville Regional Water Quality Supervisor FAYETTEWILE
FROM: Sue Homewood D , REG. OFFICE
SUBJECT: Notification of Facility Number Change
The following changes have been made to the Animal Operations Database. Please make
appropriate changes in your files.
Facility numbers 82-30 and 82-31 were combined under one facility number. Facility
number 82-31 was deleted from the animal operations database.
If you have any comments or questions please feel free to call me at [phone] ext 502.
P.O. Box 29535, Raleigh, North Carolina 27626.0535 Telephone [phone] Fax [phone]
An Equal Opportunity Aftmative Action Employer 50% recycled/10% post -consumer paper

Facility Number and Name: Mur h 's 82-30 CC/Tomahawk Farm
Instructions on last page
_eD�schar e s ... 4. ._ __�
.� .. Hi hFreetoards`-.
Wettable Acres
Description of Concern
P
- _ w -7 i _ >`
- s �' =
T
Have not received a request for a wettable
q
z�
=
_
V. x r
acreage determination
s
-..
r_
z i
a
r s
p Resonse
x -
= s y
Will complete determination if/when
4,
requested.
g A
Farm has 35% more land than is needed for
-
- - - -
_-
_ f
this size operation
r
Y S.
=
_
'V
fig. c ,r
_
��
:� c +a.- •; s '$'" ;�. :;x=
as -
s
aik
f �

1
Facility Number and Name: Murphy's 82--30, CC/Tomahawk Farm
Description of Concern
Response
2
Structural Issues
Instructions on last pa e
CrooWne Issues
Two unused lagoons to be closed on Compliance inspections showed
the farm. I concerns with weeds in bermuda
*Two original lagoons replaced
with new, plastic -lined lagoon and
old lagoons although unused
remain in the CAWMP.
*Visual inspection of current
lagoon structure on 6/11/2001
revealed no structural issues.
*Two unused lagoons will be
closed by 12/2002.
fields in 98 and 99.
Murphy Farms is not aware of any
cropping issues at this site. New land
was added and sprigged with coastal
bermuda in '98.
Visual inspection of site on
6/11/2001 revealed a good stand of
bermuda on all fields.

1
1 Concerns are based upon DWQ records consisting of deficiencies noted in state inspection reports, NOVs, penalty assessments and/or reports submitted to DWQ by the farm. Carefully
review your records to identify the specific concern or concerns and then describe the concern under the appropriate heading together with a reference to the specific record and the date of
the record (i.e., inspection report. dated or NOV dated ). With the exception of "discharges," which cover calendar year 2000, concerns are based on DWQ records for the
calendar years beginning January 1, 1996, and ending December 31, 2000.
Describe in as much detail as possible how the concern has been addressed, or, if it has not been addressed, the measures the farm intends to undertake to address the concern and a
schedule for completing the measures-
3 if subsurface drains are present, state whether you know that the drain(s) is discharging groundwater uncontaminated by hog waste, and if so, the basis for that conclusion.

r
Facility Number and Name: Murphy's 82-30, CC/Tomahawk Farm
Instructions on last page
AwDscliar
Wettable Acres
Description of Concern
X f. -A 13
4e p I., �7
Have
H not received a request for a wettable
T
acreage determination
J�
Z'
jr
17
2 7.�
W �L
2
Response
--7;7 -Fa --L7
7:j a
r- �: 11 -, T I" - ,
R_
. - �g .
7
Will complete determination if/when
ip-'4'
111�
'. 4 ­7 7 ;
requested.
4 f ff; I ��i k
Jj
M
Farm has 35% land than is for
.4
more needed
t
-:9
this size operation
�y 3�
j
6�
7:7 -2 4f
T
2-
4
V­ -
zip, _4
9w.
i6
71
T
q j-
T
"*`
1E 7
Al
J-�
1.2

Facility Number and Name: Murphy's 82-30, CC/Tomahawk Farm
Description of Concern
Response
2
Instructions on last page
Structural Issues
Two unused lagoons to be closed on
the farm.
*Two original lagoons replaced
with new, plastic -lined lagoon and
old lagoons although unused
remain in the CAWMP.
*Visual inspection of current
lagoon structure on 6/11/2001
revealed no structural issues.
*Two unused lagoons will be
closed by 12/2002.
Cropping Issues
Compliance inspections showed
concerns with weeds in bermuda
fields in 98 and 99.
Murphy Farms is not aware of any
cropping issues at this site. New land
was added and sprigged with coastal
bermuda in '98.
Visual inspection of site on
6/11/2001 revealed a good stand of
bermuda on all fields.

r Z
t Concerns are based upon DWQ records consisting of deficiencies noted in state inspection reports, NOVs, penalty assessments and/or reports submitted to DWQ by the faun. Carefully
review your records to identify the specific concern or concerns and then describe the concern under the appropriate heading together with a reference to the specific record and the date of
the record (i.e., inspection report dated or NOV dated ). With the exception of "discharges," which cover calendar year 2000, concerns are based on DWQ records for the
calendar years beginning January 1, 1996, and ending December 31, 2000.
Z Describe in as much detail as possible how the concern has been addressed, or, if it has not been addressed, the measures the farm intends to undertake to address the concern and a
schedule for completing the measures.
3 If subsurface drains are present, state whether you know that the drain(s) is discharging groundwater uncontaminated by hog waste, and if so, the basis for that conclusion.

State of North Carolina
Department of Environment' -
and Natural Resources
Division of Water Quality
�..
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E.,
Director
March 20, 1998
CERTIFIED MAIL
+' ECEIPT REOUESTED
murpnyi~.r amuyt:r arms
CC/Tomahawk Farm
3361 CC Road
Harrells NC 28444
Farm Number: 82 - 30
Dear MurphyEFamilyEFarms :
F1.9?FA
00
You are hereby notified that CC/Tomahawk Farm, in accordance with G.S. 143-215.1OC, must
apply for coverage under an Animal Waste Operation General Permit. Upon receipt of this letter, your
farm has six 60 days to submit the attached application and all supporting documentation. In
accordance with hapter 626 of 1995 Session Laws (Regular Session 1996), Section 19(c)(2), any
owner or operator who fails to submit an application by the date specified by the Department
SHALL NOT OPERATE the animal waste system after the specified date. Your application must
be returned within sixty (60) days of receipt of this letter. Failure to submit the application as required
may also subject your facility to a civil penalty and other enforcement actions for each day the facility is
operated following the due date of the application.
The attached application has been partially completed using information listed in your Animal
Waste Management Plan Certification Form. If any of the general or operation information listed is
incorrect please make corrections as noted on the application before returning the application package.
The signed original application, one copy of the signed application, two copies of a general location
map, and two copies of the Certified Animal Waste Management Plan must be returned to complete the
application package. The completed package should be sent to the following address:
North Carolina Division of Water Quality
Water Quality Section
Non -Discharge Permitting Unit
Post Office Box 29535
Raleigh, NC 27626-0535
If you have any questions concerning this letter, please call J R Joshi at [phone] extension
363 or Jeffery Brown with the Fayetteville Regional Office at [phone].
Sincerely,
4v" A. Preston Howard, Jr., P.E.
cc: Permit File (w/o encl.)
Fayetteville Regional Office (w/o encl.)
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

f�o 4.
State of North Carolina ,
Department of Environment and Natural Resources`AT:'�E� = '
Division of Water Quality
Non -Discharge Permit Application Form1
(THIS FORM MAYBE PHOTOCOPIED FOR USE AS AN ORIGINAL)
General Permit - Existing Liquid Animal Waste Operations ,, ....
The following questions have been completed utilizing information on file with the Division. -Please
review the information for completeness and make any corrections which are appropriate. If a
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
I. GENERAL INFORMATION:
1.1 Facility Name: CC/Tomahawk Farm rl C,
1.2 Print Land Owner's name: MurphytFamilyEFarms 4 Anne
r—
1.3 Mailing address: 3361 CC Road
City, State: Harrells NC Zip: 28444 rr't^ t t —A iLLE
REG. OFMICE
Telephone Number (include area code): 910-532-4744
1.4 County where facility is located: Sampson
1.5 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a
copy of a county road map with the location of the farm identified): On the west side of SR 1131 approx. 1 mile north of
its intersection with Hwy 41 at Tomahawk, NC.
1.6 Print Farm Manager's name (if different from Land Owner): Calvin Hall
1.7 Lessee's / Integrator's name (if applicable; please circle which type is listed): Murphy EFamilylFarms
1.8 Date Facility Originally Began Operation: 03/01/87
1.9 Date(s) of Facility Expansion(s) (if applicable):
2. OPERATION INFORMATION:
2.1 Facility No.: 82 (county number); 3O (facility number).
2.2 Operation Descrip on: Swine operation
_Teeder to Finish
12240- Certified Design Capacity
Is the above information correct? =yes; r`-1no. If no, correct below using the design capacity of the facility
The "No. of Animals" should be the maximum numVe-rrIlor which the waste management St:•uctures-were designed.
Type of Swine No. of Animals Type of Poultry No. of Animals Type of Cattle No. of Animals
0 Wean to Feeder 0 Layer 0 Dairy
0 Feeder to Finish 0 Non -Layer 0 Beef
0 Farrow to Wean (# sow) 0 Turkey
0 Farrow to Feeder (# sow)
0 Farrow to Finish (# sow)
Other Type of Livestock on the farm: No. of Animals:
FORM: AWO-G-E 1/26/98 Page 1 of 4

3.
2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): 126.3 ; Required Acreage (as listed in the AWMP): 126.3
2.4 Are subsurface drains present within 100' of any of the application fields? YES NO please circle one)
2.5 Are subsurface drains present in the vicinity or under the lagoon(s)? YES or O ( lease circle one)
2.6 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, NRCS Standards, etc.) (Swine Only)
YES or NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited?
What was the date that this facility's land application areas were sited?
REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
Applicants Initials
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit
application for animal waste operations.
The CAWMP must include the following components:
3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application.
3.3.4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application field.
3.3.8 The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.3.10 A site schematic.
3.3.11 Emergency Action Plan.
3.3.12 Insect Control Checklist with chosen best management practices noted.
3.3.13 Odor Control Checklist with chosen best management practices noted.
3.3.14 Mortality Control Checklist with the seiected method noted.
3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.)
If your CAWMP includes components not shown on this list, such as an irrigation design,
or site evaluation, please include the additional components with your submittal.
FORM: AWO-G-E 1/28/98 Page 2 of 4

Facility Number: 82 - 30
Facility Name: CC/Tomahawk Farm
4. APPLICANT'S CERTIFICATION:
(Land Owner's name listed in question 1.2), attest that
this application for C_Q__ 7-n ►�,�hc ►_,� K t G.r (Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned to me as incomplete.
Signature
Date `3 —9L
5. MANAGER'S CERTIFICATION: (complete only if different from the Land Owner)
4 Zl [ ( (Manager's name listed in question 1.6), attest that this
application for (Facility name listed in question I.1)
has been reviewed y me ad is accurate and complete tote best ot my knowledge. I under d that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned tnco llete. c
Signature / �v r MLZC ~� Date Y .3r/'
THE COMPLETV APPLICATION PA.GKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
FORM: AWO-G-E 1/28/98 Page 3 of 4

DIN ISION OF NVATER QUALITY REGIONAL.OFFICES (1198)
Asheville Regional VA'Q Supervisor
59 Woodfin Place
Asheville, NC 29801
[phone]
Fax [phone]
Avery
Macon
Buncombe
Madison
Burke
McDowell
Caldwell
Mitchell
Cherokee
Polk
Clay
Rutherford
Graham
Swain
Havwood
Transylvania
Henderson
Yancey
Jackson
Fayetteville Regional WQ Supervisor
Wachovia Building, Suite 714
Fayetteville, NC 28301
(9i0)486-1541
Fax [phone]
Washington Regional WQ Supervisor
943 Washington Square Mall
Washington, NC 27889
[phone]
Fax [phone]
Beaufort Jones
Bertie
Lenoir
Camden
Martin
Chowan
Pamlico
Craven
Pasquotank
Currituck
Perquimans
Dare
Pitt
Gates
Tyreii
Greene
Washington
Hertford
Wayne
Hyde
Mooresville Regional WQ Supervisor
919 North Main Street
Mooresville, NC 28115
[phone]
Fax [phone]
Raleigh Regional WQ Supervisor
3800 Barrett Dr,
Raleigh, NC 27611
[phone]
Fax [phone]
Chatham
Nash
Durham
Northampton
Edgecombe
Orange
Franklin
Person
Granville
Vance
Halifax
Wake
Johnston
Warren
Lee
Wiison
Wilmington Region. WQ Supervisor
127 Cardinal Drive Extension
Wilmington, NC 28405-3845
[phone]
Fax [phone]
Anson
Moore
Alexander
Lincoln
Brunswick New Hanover
Bladen
Richmond
Cabarrus
Mecklenburg
Carteret Onslow
Cumberland
Robeson
Catawba
Rowan
Columbus Pender
Hamett
Sampson
Cleveland
Stanly
Duplin
Hoke
Scotland
Gaston
Union
Monteomery
iredell
Winston-Salem Regional WQ Supervisor
585 Waughtown Street
Winston-Salem, NC 27107
[phone]
Fax [phone]
Alamance
Rockinghafn
Alleghany
Randolph
Ashe
Stokes
Caswell
Surry
Davidson
Watauga
Davie
Wilkes
Forsvth
Yadkin
Guilford
FORM: AWO-G-E 1/28/98 Page 4 of 4

Grower: CSC TOMAHAWK Desigried'6.- '-r-,' ,RPB
Address: Chocked By; RMM
Date: 08101 f9T
_ , qL 7
�►N�EROSIC MITE LAG�1�N--DES1QN
F.ALiffi.11� F.0 R � AT I O N
Nursery:
Finishing:
Farrow to weanling:
Farrow to feeder:
Farrow to finish:
Boars,
Storage Period:
25 Yr. It 24 Hr Storm Event
"Heavy Rain" Factor
Rainfall In Excess of Evaporation
Additional Water Usage:
Additional Drainage Area:
F�rm�o�ation,
Not Applicable
LAOLOPP _IN-06MATION
Is Lagoon Designed as an Irregular Shape? (YIN) -----------
Does Operator Want Emergency Spillway? (YIN) ------•----
Is This Design for an Existing Farm?
(YIN) ------------"
Is Drain Tile Req'd to Lower SHWT?
(YIN) ------------
Seasonal High Water Table Elev:
----------------
i=reepoard:
.... ... .�,_____
Emergency Spillway Flow Depth:
Not Applicable
Top of Storm I Spillway Buffer:
Not Applicable
Sida Slopes:
w......w.w_....
Press ALT-C to Download
contour areas see sheet 2 of 7...
Top of Dike Elevation:
-----•--•••----«
Finished Bottom Elevation:
Start Pump Elevation:
Stop Pump Elevation:
Y
N
Y
N
0
12240 Hd.
0
0
0
0
180 Days
7.5 In,
7.5 In,
7.0 In.
0
0
98.36
Ft.
1.0
Ft.
0.3
Ft.
0,5
FL
3
:1 (H:V)
850.0
Ft.
390,0
Ft.
109.00
Ft.
97.80
Ft.
107.20
Ft.
104.00
Ft.
LAf Q0N-V ti1.11ME RMWRED-ML. R11161014M&UMES . "A.RE-QM,
Storm Stor ■
205535 (Cu.Ft.)
254,490 (Cu.Pt,)
123.82%
Temporary ■
860481 (Cu,Ft.)
975,733 (Cu,Ft.)
113.40%
Permanent =
1852400(Cu.F�_-
1,690,874 Cu,Ft.)
102.33%
Total Volume =
2,718,380 (Gu.Ft.)
2.921,497 ( u.Ft.)
Id77.4B9-4
Lagoon Surface Area: (Inside TOD)---------------
328,856 S.F.
9101.=1 Q0b968LC4i6 NC,I.I.2flmi-sNoo AAw wti S[:ZO s6-TO-NAH

- n :-, ',- -", i - I I
Tower: c9c TOMAHAWK
Designed By. Aps
Address:
Checked By: RMM
Date: 08/01107
DUPLI
Sheet 2 of 7
ACTUAL--.-DESIGN---VDL,UME,.--CA.k-C-ULAT.IONB
-LAPQQN 0,TA.GZ--AREA. VO kUMS
Contour
Elmaort.(Fl)
&mLffl
Kct-Vol.- (-Cu.
-ET) CumuL.Vol. (Cu,.Fl�
97.80
252,256
98.00
253,549
50,580
50,580
99.00
260,057
250,803
307,383
100-00
266,632
263,345
570,728
101.00
273,275
269,954
840,681
102.00
279,986
270,631
1,117,312
103.00
206,764
283,375
1,400,687
104.00
293,610
290,187
1,690,874
105.00
300,524
297,067
1,987,941
106-00
307,505
304,015
2,291,956
107.00
314,554
311,030
2,602,985
108.00
321,671
318,113
2,921,097
109.00
328,856
325,264
3,246,381
----f0TAL:KEQ1JV6MPI
ENDPUMP= . . . >
START PUMP = = m >
MAX STORAGE = = >
t-4 sing fH& vertical avers ga and area method,
Ta,386 CF
107.4-CO
104.00 IFT
1,690,874 CF
TR'MT
1100,874
102J3i%-
107.20 FT
2,666,807 CF
TEMP
075,733
113.40%
108.00 FT
2321,097 CF
STOR
254,490
123,8211/61
F;O*cj 90V9687A16 NOTionNISNOO --AAW Wtj S1:Z0 86-T0-N�4H

.. .
TOIkI�NAbii�
PRG[ -)ERTY
1 n[1 rtn () •l

iL 1"
IOGi 2 2003
Wettable Acres Determination Certification
Name of Pacility: , C C �, �nr% k Facility Number '6� -3 O
Owner(s) Name: '(Y1 11C Phone No:_23S 1� 11 l
Mailing Address: Q ,C 2Q 6 c5
e 1a;1 i �) �5
By signing this form, the facility owner and Technical Specialist acknowledge the completion of the
Wettable Acres Determination. All necessary Wettable Acre Determination Field Data Sheets and
calculations were completed to conduct a Wettable Acre Determination. The facility's Waste
UtMzation Plan has been amended as necessary to reflect actual wetted acreage. A copy of all
worksheets, calculations, and other Wettable Acres Determination documents, along with the
applicable Waste Utilization Plana and Wettable Acre Determination Certification will be filed with
the local Soil and Water Conservation District. A copy will also be kept on site with the Certified
Animal Waste Management Plan. Any future modifications must be approved by a technical
specialist and filed with the Soil and Water Conservation District prior to implementation. If any
modifications to tiag existing; irrigation system ar a4y new irr�ratig�equipmgnt rgquiz�ed tQ.
adequately address the waste management needs of this facility, an ]rrigation Specialist or
Professional Engineer has certified the design and installation below.
Owner Name:
Owner Signature:
Technical Specialist
Technical Specialist
If assisted by an Irrigation Specialist or Professional Engineer please read and sign below:
Animal waste application equipment bas been designed or modified to apply waste as necessary to
accommodate the waste management plan and according to NRCS Standards. Animal waste
application eg0prnow has been installed according to MRCS Standards and is ready for use.
Irrigation Specialist/PE Name:
Irrigation Specialist/PE Signature-^ Date:
Submit this form to:
Attn: Sonya Avant
Eton -Discharge Compliance Unit
Division of Water Quality
1617 Mail Service Center
Raleigh, NC 27699-1617
WADC - 7199
�..,...I In ...11 A1. 1 .1. 1... r I -r 1 111.1 .I 1 ... wn
1.1 �/ n i n 1.

I9
Irrigated Acreage Determination Procedures
for Wastewater Application Equipment
Hard Hose Traveling Gun System
FIELD DATA WORKSHEET*
1. Make and model number �'& 1\0�' n \ -3 (� ,
2. Hose length )oa O [feet] and hose inside diameter (ID) [inch]
3. Gun make and model number C\fSon 15jC�
4. Gun nozzle size [inch], ring orifice, taper bore orifice
5. Gun arc angle [degrees]
6. Travel lane spacing a up [feet]. Indicate whether ✓ uniform or random.
Number of exterior hydrants 5. Number of interior hydrants
3tao *
7. Gun wetted diameter o1y [feet]. measured or L,-' based on gun chart.
8. Gun pressure SO , [psi] observed at working gauge,
determined from gun charts, calculated (show calculations)
**4. Operating pressure at hose reel [psi]. observed at working gauge or
provided by owner.
**10. Supply line size [inch] (from pump to last hydrant)
**11. Supply line length feet (maximum pumping distance)
**12. Supply line type PVC or aluminum
**13. Pump make and model number
**14. Pump capacity a S [gpm]
**15. Engine make and model number
or
**16. Electric motor horsepower and rpm [hp] [rpm]
Note: It is strongly recommended that you field determine wetted diameter and operating
pressure at the reel and gun.
* Locate each hydrant on a copy of the map. Indicate the start and stop of the sprinkler cart
for each travel lane and show the distance traveled. Show the location of the supply line.
Irrigated acres are determined by the travel lane.
** Optional data, furnish where possible.
*** Information furnished by
_ and/or
Signature of owner or facility representative
R., L" YA SSA-h_..,..,
Printed name of owner or fadlity representative .
Date OL d 3
1
Signature of technical specialist
Printed name of technical specialist
Date
*** Only the person or people collecting the data should sign the Field Data Worksheet.
11
8

(Multiple worksheets may be needed) HARD HOSE TRAVELER
IRRIGATION SYSTEM
Hard Hose Traveling Gun System
COMPUTATIONAL WORKSHEET
1. Farm number (identification) Cc 1-6,--�a-'Tleld number (identification) 1
2. Irrigation system designation -'- Existing Irrigation system New/expanded irrigation system
3. Number of travel lanes —,-:# # Interior lanes _� # Exterior lanes feet] Length of pull(LI)
# Interior lanes # Exterior lanes [feet] Length of pull(L2)
3� .cq # Interior lanes # Exterior lanes [feet] Length of pull(L3)
4. Wetted diameter a.1u [feet] from Field Data Worksheet
5. Spacing 2qb Hydrant spacing [feet] '9q% [as a percentage of wetted diameter]
6. Hydrant layout Multiple hydrants Single hydrant Excessively spaced hydrants
7. Read the irrigated area per travel pull for the given wetted diameter from the appropriate table and column
based on pattern, spacing, and travel lane location.
Travel lane length (L_) ✓Interior or Exterior pane/hydrant)
Dui (a) Acres start end of pull from Tablet-- Column �J
31 (b) Acres middle portion of pull (LI)
(Pull length k�j [feet] X Wetted width. %) [feet])/ 43,560
(c) Acres stop end of pull from Table �a?y Column
3.q Total acres for travel lane length (LI) (Sion: a + b + c)
Travel lane length (L,_) ✓Interior or Exterior (Iane/hydrant)
.L03 (a) Acres start end of pull from Table L_ 1� 40 Column
�a (b) Acres middle portion of pull (1,2)
(Kill Iength �g5, ' [feet] X Wetted width a46'[feet)) / 43,560
(c) Acres stop end of pit11 from Table -.q— Column
09 Q, Total acres for travel lane length (L2) (Sum; a + b + c)
Travel lane length (Ij Interior or Zaterlor (lane/hydrant)
6Li (a) Acres start end of pull from Table o Column `a
3 (b) Acres middle portion of pull (L3
0�-� . {Pull length �5 , [feet] X Wette'dOwidth QsS ' [feet]) / 43,560
(c) Acres stop end of pull from 'lhble L' C--qColumn
,o Total Acres for travel lane length (13) (Sum: a + b + c)
8. Multiply the tabulated irrigated acreage value per travel pull by the number of pulls of each
category in the field. Add all of these, and this is the total irrigated acreage for the field.
(a) Acres per travel lane length (L1)
(b) Acres per travel lane' length (L2)
(c) Acres per travel lane length (L3)
X # Lanes =
X # Lanes
Acres
Acres
X # Lanes = Acres
Total CAWMP wettable acres for Held (Sum: 8a + 8b + 8c)
Wettable Acre Computational Worksheet Completed by. Date: Lt
Signature of technical s clalist
�S

(Multiple worksheets may be needed)
Hard Hose Traveling Gun System
COMPUTATIONAL WORKSHEET
HARD HOSE TRAVELER
IRRIGATION SYSTEM
1. Farm number (identification) 0C number (Identification)
2. Irrigation system designation -%�- Existing Irrigation system New/expanded irrigation system
3. Number of travel lanes # Interior lanes # Exterior lanes feet] Length of pull(L1)
# Interior lanes # Exterior lanes [feet) Length of pull(L2)
# Interior lanes # Exterior lanes __ (feet] Length of pull(L3)
4. Wetted diameter [feet] from Field Data Worksheet
5. Spacing �-qcs Hydrant spacing (feet) '? [as a percentage of wetted diameter]
6. Hydrant layout ✓Multiple hydrants Single hydrant Excessively spaced hydrants
7. Read the irrigated area per travel pull for the given wetted diameter from the appropriate table and column
based on pattern, spacing, and travel lane location.
Travel lane length (L) interior or Exterior (lane/hydrant)
(a) Acres start end of pull from Table f Go Column
�.Sa (b) Acres middle portion of pull (1f1)
(Pull length go—b (feet] X Wetted width A-kS_ (feet)] / 43,560
(c) Acres stop end of pull from Table L cGn Column
`�(.2 Total acres for travel lane length (Ll) (Sum: a + b + c)
Travel lane length (L.J _ Interior or ✓ Exterior (lane/hydrant)
o S1 (a) Acres start end of pull from Table Column
(b) Acres middle portion of pull (LZ)
{moo �4oFa
(Pull length�Q [feet] X Wetted width 3 (feet]) / 43,560
_ (c) Acres stop end of pull from Table -�.-LaDColumn
Li S 7 Total acres for travel lane length (12) (Sum: a + b + c)
Travel lane length (L-) Interior or �Fxterior (lane/hydrant)
..,3�L- (a) Acres start end of pull from Table Lam_ Column
34 (b) Acres middle portion of pull (L3) i �o + q e
(Pull length oo [feet) X Wetted width! [feet]} / 43,560
(c) Acres stop end of pull from Table Column
±Gl. Total acres for travel lane length (13) (Sum: a + b + c)
8. Multiply the tabulated irrigated acreage value per travel pull by the number of pulls of each
category in the field. Add all of these, and this is the total irrigated acreage for the field.
(a) Acres per travel lane length (L1)
(b) Acres per travel lane length (L2)
(c) Acres per travel lane length (L3)
X # Lanes = Acres
X # Lanes Acres
X # Lanes = Acres
13',39 Total GAWP. wettable acres for field (Sara: 8a + 8b + 8c)
Wettable Acre Computational Worksheet Completed by Date:
Signature of technical sip) alist
�rs

{Multiple workaheerl may be needed) HARD HOSE TRAVELER
IRRIGATION SYSTEM
Hard Hose Traveling Gun System
COMPUTATIONAL WORKSHEET
1. Farm number (identification) CC I -To4, ,jkkField number (identification) t
2. Irrigation system designation ,Existing irrigation system New/expanded irrigation system
3. Number of travel lanes # Interior lanes # Exterior lanes feet] Length of pull(LI)
# Interior lanes # Exterior lanes [feet] Length of pull(L2)
# Interior lanes # Exterior lanes [feet] length of pull(L3)
4. Wetted diameter [feet] from Field Data Worksheet
5. Spacing a.Uu Hydrant spacing [feet] 52L'� jA [as a percentage of wetted diameter]
6. Hydrant layout _,� Multiple hydrants Single hydrant Excessively spaced hydrants
7. Read the irrigated area per travel pull for the given wetted diameter from the appropriate table and column
based on pattern, spacing, and travel lane location.
Travel lane length (L-) ✓ [nterior or Exterior (lane/hydrant)
.l� (a) Acres start end of pull from Table �- i °'� Column d
(b) Acres middle portion of pull (U)
(x'1j (Pull length -J � [feet] X Wetted width a*O [feet]) / 43,560
(c) Acres stop end of pull from Table ��l alc- Column
+ � Total acres for t-ravel lane length (LI) (Silm: a + b + c)
,4 Travel lane length (L-) ✓Interior or Exterior Oane/hydrant)
U3 (a) Acres start end of pull from Table J�jct Z_ Column
u •34 (b) Acres middle portion of pull (L2)
(Pull length 78 [feet] X Wetted width �tj [feet]) / 43,560
(c) Acres stop end of pull from Table lc��l Column
Total acres for travel lane length (L2) (Sum: a + b + c)
Travel lane length (L- Interior or ✓Exterior (lane/hydrant)
Loco (a) Acres start end of pull from Table Column
! lL1 (b) Acres middle xa n of pull (L3) z • ,q s
(Pull length 'r'�,! Tfeet) X Wetted width ��o [feet]} / 43,560
(c) Acres stop end of pull from Table Column
Total acres for travel lane length (U) (Sum: a + b + c)
8. Multiply the tabulated irrigated acreage value per travel pull by the number of pulls of each
category in the field. Add all of these, and this is the total irrigated acreage for the field.
(a) Acres per travel Iane length (LI) X # Lanes = Acres
(b) Acres per travel lane length (L2) X _ # Lanes = Acres
(c) Acres per travel lane length (W) X # Lanes = Acres
i-�,b i Total GAWP, we)t#able acres for field (Sum: 8a + 8b + 8c)
Wettable Acre Computational Worksheet Completed by- Date; �o �-
signature of technical s ciallst

(Multiple worksheets may he needed) HARD HOSE TRAVELER
IRRIGATION SYSTEM
Hard Hose Traveling Gun System
COMPUTATIONAL WORKSHEET
1. Farm number (identification) 0-0 1 ITor*�•Vlc-�Jfleld number (identification) t
2. Irrigation system designations Existing irrigation system _ New/expanded irrigation system
3. Number of travel lanes # Interior lanes # Exterior lanes r. feet] Length of pull(L1)
# Interior lanes # Exterior lanes [feet] Length of pull(L2)
# Interior lanes # Exterior lanes [feet] Length of pull(L3)
4. Wetted diameter [feet] from Field Data Worksheet
5. Spacing ,jc Hydrant spacing [feet] _�_ [as a percentage of wetted diameter]
6. Hydrant layout , 2, v ultiple hydrants Single hydrant Excessively spaced hydrants
7. Read the irrigated area per travel pull for the given wetted diameter from the appropriate table and column
based on pattern, spacing, and travel lane location.
Travel lane length (Q ::� terior or Exteriof pane/hydrant)
(o3 (a) Acres start end of pull from Table Leg d Column
`t•5 (b) Acres middle portion of pull (Ll)
l o (Pull length—IbM [feet] X Wetted widtha-l0' [feet])/ 43,560
(c) Acres stop end of pull from Table � o Column
Total acres for travel lane length (M) (Sinn: a + b + c)
Travel lane length (L) Interior or ZExterior (lane hydrant)
SC%_ .31 (a) Acres start end of pull from Table G L9 0 Column - -
.5� (b) Acres middle portion of pull (L2
(full length ►V [feet] X Wett'dVid h ass [feet]) / 43,560
(c) Acres stop end of pill from Table - LG Column
-• t4 . Total acres for travel lane length (L2) (Sinn: a + b + c)
Travel lane length (L_) ?-rnterior or __-Exterior (lane/hydrant)
(a) Acres start end of pull from Table VlgQ Column
LLS�f (b) Acres middle portion of pull (13)
�-� (Pull length `,[feet] X Wetted width [feet]) / 43,560
(c) Acres stop end of pull from, Table " -�0 Column
'� a I Total acres for travel lane length (13) (Snm: a + b + c)
8. Multiply the tabulated irrigated acreage value per travel pull by the number of pulls of each
category in the field. Add all of these, and this Is the total irrigated acreage for the field.
.� (a) Acres per travel lane length (L1) X # Lanes = Acres
(b) Acres per travel lane length (L2) X # Lanes = _ _ Acres
(c) Acres per travel lane length (L3) X # Lanes = ___r__r__ Acres
11, a G Total CAWMP wettable acres for field (Sure: 8a + 8b + 8c)
Wettable Acre Computational Worksheet Completed by: Date:
Signature of technical sp ciallst
Dis

(Muldple worksheets may be needed) HARD HOSE TRAVELER
IRRIGATION SYSTEM
4 Hard Hose Traveling Gun System
COMPUTATIONAL WORKSHEET
1. Farm number (identification) CC i Field number (identification) 1
2, Irrigation system designation ✓ Existing Irrigation system New/expanded irrigation system
3. Number of travel lanes # Interior lanes # Exterior lanes feet) Length of pull(L1)
# Interior lanes # Exterior lanes [feet] Length of pull(L2)
# Interior lanes # Exterior lanes [feet] Length of pull(L3)
4. Wetted diameter as [feet] from Field Data Worksheet
5. Spacing --k4D Hydrant spacing [feet] YP'7,, [as a percentage of wetted diameter]
6. Hydrant layout Multiple hydrants Single hydrant Excessively spaced hydrants
7, Read the irrigated area per travel pull for the given wetted diameter from the appropriate table and column
based on pattern, spacing, and travel lane location.
Mravel lane length (L-) interior or —1z6teriof (lane/hydrant)
.3A (a) Acres start end of pull from Table Column
1, 0�. (b) Acres middle portion of pull (LI)� rim
13 (Pull lengths [feet] X Wetted width aaO [feet]{ / 43,560
(c) Acres stop end of pull from Table C EPIy Column
1. 3g Total acres for travel lane length (11un ) (St: a + b + c)
(, Travel lane length (L) Interior or ✓Exterior Bane/hydrant)
o _e �q (a) Acres start end of pull from TableaColumn
3q G, (b) Acres middle portion of pull (12)
I ptido
y 4 (full length 950 [feet] X Wetted width l3a ffeetjl / 43,560
(c) Acres stop end of pull from Table Column
4-L4S Total acres for travel lane length (1,2) (Sum: a + b + c)
�--
Travel lane length (Ij Interior or tf6terlor (lane/hydrant)
• �A 1 (a) Acres start end of pull from Table CE �S0 Column
(b) Acres middle portion of pull (1-3
5 {Pull length `iCoO [feet] X Wetted width135 ]feet]) / 43,564
(c) Acres stop end of pull from Table �C C�Column
3 'c) ,2 Total acres for travel lane length (U) (Sam: a + b + c)
8. Multiply the tabulated irrigated acreage value per travel pull by the number of pulls of each
category in the field. Add all of these, and this is the total Irrigated acreage for the field.
(a) Acres per travel lane length (M) X # Lanes = _ Acres
(b) Acres per travel lane length (1,2) X # Lanes Acres
(c) Acres per travel lane length (L3) -X # Lanes = Acres
.ga Total CAVJW. wettable acres for field (Sum: 8a 4 8b + 8c)
Wettable Aae Computational Worksheet Completed by: Date:�- 0 3
Signature of technical specialist

(Multiple worksheets may be needed) HARD HOSE TRAVELER
IRRIGATION SYSTEM
Hard Hose Traveling Gun System
COMPUTATIONAL WORKSHEET
1. Farm number (identification) CC 10—�— - ield number (identification) -
2, Irrigation system designation sting irrigation system New/expanded irrigation system
3. Number of travel lanes # Interior lanes # Exterior lanes feet] Length of pull(L1)
# Interior lanes # Exterior lanes [feet] Length of pull(L2)
# Interior lanes # Exterior lanes [feet] Length of pull(W)
4, Wetted diameter 1D [feet] from Field Data Worksheet
S. Spacing oZ4P Hydrant spacing [feet] 'Ta-?o [as a percentage of wetted diameter]
6. Hydrant layout Multiple hydrants Single hydrant Excessively spaced hydrants
7. Read the irrigated area per travel pull for the given wetted diameter from the appropriate table and column
based on pattern, spacing, and travel lane Iocation.
Travel lane length (Ij Interior or Exterior pane/hydrant)
(a) Acres start end of pull from Table EeColumn
�3 (b) Acres middle rtion of pull (Ll) z.4S = 1' bto
f (Pull length2-&c;,[feet) X Wetted width L 1 u [Feet]) / 43,560
(c) Acres stop end of pull from Table Column
a.Total acres for travel lane length (L1) (Sean: a + b + c)
Travel lane length (L_) Interior or Exterior (lane/hydrant)
• 3 - (a) Acres start end of pull from Table , Column g
(b) Acres middle portion of pull (1,2)
4'1 (Pull length �[feet) X Wetted width a3Q [feet]) / 43,560
(c) Acres stop end of poll from Table Column
,1 q to Total acres for travel lane length (1,2) (Sum: a + b + c)
Travel lane length (L-) ✓ terior or Exterior (lane/hydrant)
(a) Acres start end of pull from Table r- � `t u Coltunn _ �
'4, 34 (b) Acres middle portion of pull (L3)
4 (Pull length'aa5 [feet] X Wetted width , b [feet]) / 43,560
(c) Acres stop end of pull from 'Cable Column
4 6e Total acres for travel lane length (13) (Sum: a + b + c)
8. Multiply the tabulated Irrigated acreage value per travel pull by the number of pulls of each
category in the field. Add all of these, and this is the total irrigated acreage for the field.
(a) Acres per travel lane length (LI)
(b) Acres per travel lane length (L2)
(c) Acres per travel lane length (L3)
X# Lanes
X # Lanes
X # Lanes
Acres
Acres
Acres
10, 51% Total CAWMP, wettable acres for Held (Sum: 8a + 8b + 8c)
Wettable Acre Computational Worksheet Completed by: Date: (o -
Signature of technical spe alist

(Multiple worksheets may be needed)
Hard Hose Traveling Gun System
COMPUTATIONAL WORKSHEET
HARD HOSE TRAVELER
IRRIGATION SYSTEM
1. Farm number (identification) qQ j aor�-*field number (identification) -D-
2. Irrigation system designation _�Exlsting irrigation system New/expanded irrigation system
3. Number of travel lanes # Interior lanes # Exterior lanes feet[ Length of pull(Ll)
# Interior lanes # Exterior lanes [feet] Length of pull(L2)
# Interior lanes # Exterior lanes r [feet] Length of pull(L3)
4. Wetted diameter 3_D�p [feet] from Field Data Worksheet
5. Spacing ate_ Hydrant spacing [feet] at ? ca [as a percentage of wetted diameter]
6. Hydrant layout Multiple hydrants Single hydrant Excessively spaced hydrants
7. Read the irrigated area per travel pull for the given wetted diameter from the appropriate table and column
based on pattern, spacing, and travel lane location,
7kavel lane length (Iaj Interior or Exterior pane/hydrant)
-._(&l (a) Acres start end of pull from Tabled Ca Column d
o-C)2�, (b) Acres middle portion of pull (L1)
1 q [Pull lengthy [feetj X Wetted width a-� [feet]) / 43,560
(c) Acres stop end of pull from Table Column
S Total acres fortravellane length (LI) (Stun: a + b + c)
Travel lane length (L-) ZInterior or Exterior (lane/hydrant)
6b (a) Acres start end of pull from TableCQ-q0 Column
3 , 64 (b) Acres middle portion of pull (L2)
(Rill length iAQ [feet] X Wetted width D-LI 0 [feet]) / 43,560
(c) Acres stop end of pull from Table Coluinn
a Total acres for travel lane length (L2) (Sum: a + b + c)
Travel lane length (I-) ✓Interior or Exterior (lane/hydrant)
�l _ (a) Acres start end of pull from 'Fable S `s 2 Column
145 (b) Acres middle portion of pull (L3)
a (Pull length (ea5 [feet] X Wetted width a40[feet]} / 43,560
(C) Acres stop end of pull from 7hble Column
L4,06 Total acres for travel lane length (U) (Sum: a + b + c)
8. Multiply the tabulated irrigated acreage value per travel pull by the number of pulls of each
category In the field. Add all of these, and this is the total irrigated acreage for the field.
(a) Acres per travel lane length (Ll)
(b) Acres per travel lane length (L2)
(c) Acres per travel lane length (L3)
X # Lanes =
X # Lanes
X # Lanes
Acres
Acres
= Acres
Total CAWMP wettable acres for field (Sum: 8a + 8b + 8c)
Wettable Acre Computational Worksheet Completed b . l
13 p Y' Date: `
Signature of technical speciAA

(MudMple worksheets may be needed) HARD HOSE TRAVELER
IRRIGATION SYSTEM
Hard Hose Traveling Gun System
COMPUTATIONAL WORKSHEET
1. Farm number (identification) CL TOLY) wield number (identification) Z
2. Irrigation system designation ✓ Existing irrigation system New/expanded irrigation system
3. Number of travel lanes # Interior lanes # Exterior lanes feet) Length of pull(LI)
# Interior lanes # Exterior lanes [feet] Length of pull(L2)
# Interior lanes # Exterior lanes [feet) Length of pull(L3)
4. Wetted diameter a10[feet] from Field Data Worksheet
5, Spacing Hydrant spacing [feet] 'R72o [as a percentage of wetted diameter]
6. Hydrant layout Multiple hydrants Single hydrant Excessively spaced hydrants
7. Read the irrigated area per travel pull for the given wetted diameter from the appropriate table and column
based on pattern, spacing, and travel lane location.
'raven lane length (L-) Zinterior or Exterior (lane/hydrant)
(a) Acres start end of pull from Table L7 q6 Column �
&�(b) Acres middle portion of pull (Ll)
a� [Pull length�C [feet] X Wetted width a4b [feet]l / 43,560
(c) Acres stop end of pull from Table Column
Total acres For travel lane length (M) (Suns; a + b + c)
Travel lame length (L_) �Interior or Exterior (lane/hydrant)
lfl3 (a) Acres start end of pull from Table -Zao) C Column
(b) Acres middle portion of pull (L2)
{Pull length')AQ [feet) X Wetted width a4�3 [feet]) / 43,560
(c) Acres stop end of pull from Table Column
�}- lo& Total acres for travel Iane length (L2) (Sum: a + b + c)
Travel lane length (L.) L--"]'nterior or ---,Exterior (lane/hydrant)
lnZ (a) Acres start end of pull from Table i- li 9 g Column C)
I (b) Acres middle portion of pull (L3)
au f Pull lengtha� [feet] X Wetted width �L40 [feet]) / 43,560
(c) Acres stop end of pull from `fable _ _ Column
a•0 I Total acres for travel lane length (U) (Sum: a + b + c)
8. Multiply the tabulated irrigated acreage value per travel pull by the number of pulls of each
category in the field. Add all of these, and this is the total irrigated acreage for the field.
(a) Awes per travel lane length (L1) X # Lanes = Acres
(b) Acres per travel lane length (L2) X # Lanes = _ Acres
(e) Acres per travel lane length (U) -X # Lanes = Acres
q AS Total CAWM . wettable acres for field (Sum: 8a + 8b + 8c)
Wettable Acre Computational Worksheet Completed by: Date-�o 4r6-03
Signature of technical specialist
IS

(Multiple worhheers may be needed) HARD HOSE TRAVELER
IRRIGATION SYSTEM
Hard Hose Traveling Gun System
COMPUTATIONAL WORKSHEET
1. Farm number (identification) 00 1Tome Yield number (identification) 2
2. Irrigation system designation ✓Existing irrigation system New/expanded Irrigation system
3. Number of travel lanes -_ # Interior lanes # Exterior lanes feet) Length of pull(LI)
# Interior lanes # Exterior lanes [feet] Length of pull(L2)
# Interior lanes # Exterior lanes [feet) Length of pull(L3)
4. Wetted diameter aD O[feet] from Field Data Worksheet
5. Sparing aLuc-U_ Hydrant spacing [feet] $`u `Z o [as a percentage of wetted diameter]
6. Hydrant layout Multiple hydrants Single hydrant Excessively spaced hydrants
7. Read the irrigated area per travel pull for the given wetted diameter from the appropriate table and column
based on pattern, spacing, and travel lane location.
Travel lane length (L_) Interior or _acterior (lane/hydrant)
. 1oH (a) Acres start end of pull from Table CiPy Column
y as (b) Acres middle portion of pull (LI)
as {Pull length1-4-0 [feet) X Wetted width, � [feet)l / 43,560
(c) Acres stop end of pull from Table _ Column
5 (_v Total acres for travel lane length (L1) (Sean: a + b + c)
Travel lane length (L-) Interior or _a,CExterior (lane/hydrant)
(a) Acres start end of pull from Table EEO Column �>
,�l l (b) Acres middle portion of pull (L2)
(Nil] length 70 [feet) X Wetted width ;S-S [feet)] / 43,560
(c) Acres stop end of pull from Table Column
7 3 Total acres for travel lane length (L2) (Sum: a + b + c)
Travel lane length (L, Interior or _Exterior (lane/hydrant)
(a) Acres start end of pull from Table Column
(b) Acres middle portion of pull (1,3)
(Pull length [feet] X Wetted width [feet]) / 43,560
(c) Acres stop end of pull from Table Column
Total acres for travel lane length (L3) (Sum: a + b + c)
8. Multiply the tabulated irrigated acreage value per travel pull by the number of pulls of each
category in the field. Add all of these, and this is the total irrigated acreage for the field.
(a) Acres per travel lane length (LI)
(b) Acres per travel lane length (1,2)
(c) Acres per travel lane length (L3)
X # Lanes
X # .Lanes
X _. _ # Lanes
Acres
Acres
Acres
eo.'a9 Total CAWMP. wegtable acres for field (Sum: 8a + 8b + 8c)
Wettable Acre Computational Worksheet Completed by: Y,, Date;
Signature of technical sp alist

t(' � r M'4t"jt .S!'..€' fi tip ,T, `ii" of • 1. j^� ,,��' „in�er�:5u^e.r;w*uwnro-;c, emu. m�wrt�ncrr. �e•�s^ �.t � � ..,i � �• �. �-� i ] n t � - i
PRODUCER: CC / TOMAHAWK -- MURPHY FAMILY FARMS
LOCATION: 3361 CC ROAD; HARRELLS, NC 28444
TELEPHONE: (910) 532 - 4744
TYPE OPERATION: FEEDER - FINISH
NUMBER OF ANIMALS: 12,240
(Design Capacity)
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface and/or groundwater. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops in the fields where the waste is
to be applied. This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle. Annual soil tests are strongly encouraged so that all
plant nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and available water holding capacities. Normally waste shall not be applied to land
eroding at greater than 5 tons per acre per year. With special precautions, waste may be
applied to land eroding at up to 10 tons per year. Do not apply waste on saturated soils, when it
is raining, or when the surface is frozen. Either of these conditions may result in runoff to
surface waters which is not allowed under DEM regulations. Wind conditions should also be
considered to avoid drift and downwind odor problems. To maximize the value of nutrients for
crop production and to reduce the potential for pollution, the waste should be applied to a
growing crop or applied to bare ground not more than 30 days prior to planting. Injecting the
waste or disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for analysis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H.0217 adopted by the Environmental Management Commission.
Page 1

Amount of Waste Produced Per Year (gallons, ft, tons, etc.)
12,240 animals X 1.9 (tons) waste/animallyear =
Amount of Plant Available Nitrogen (PAN) Produced Per Year
12,240 animals X 2_3 lbs. PAN/animal/year =
Guide Std. 633)
23,256 (tons) waste/year.
28,152 lbs. PAN/year. (PAIN from N.C,
Tech
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner
The following acreage will be needed for waste application based on the crop to be grown and
surface application:
Table 1: ACRES OWNED BY PRODUCER
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
# No. Tvoe Per Acre Utilized ADDlication
CCITOM
1
To/CaB/LeA
Bermuda G
220
48.43
10,655
March - Sept
CCITOM
2
CaB
Bermuda G
200
41.66
8,332
March - Seet
all
Small Grain
50
90.09
4,505
Sept - April
CCITOM
subfield 1
ToICaBILeA
Bermuda G
220
15.37
3,381
March - Sept
CCITOM
subfield 2
CaB
Bermuda G
200
20.84
41168
March - Sept
all
Small Grain
50
36.21
1,811
Sept - A ril
Total 1 125.301 32,851.Ou 1
'This N Is from animal waste only. If nutrients from other sources such as commercial fertilizer are
applied, they must be accounted for. N must be based on realistic yield expectation.
NOTE: The applicator Is cautioned that P and K may be over applied while meeting the N
requirements. Beginning in 1996 the Coastal Zone Management Act will require farmers in some
eastern counties of North Caroline to have a nutrient management plan that addresses all nutrients.
This plan only addresses Nitrogen.
Page 2

Table 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowner must be attached)
(Required only if operator does not own adequate land [see
Required Specification 2])
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
Application2 �,1111111111!IiFype Per Acre* Utilized
* See footnote for Table 1.
Totals from above Tables
Acres Lbs. N
Utilized
Table 1 126.30 32,851
Table 2
Total 126.30 32,851
Amount of N Produced 28,152
Surplus or Deficit 4,699
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to prevent over
application of nutrient or other elements.
Page 3

See attached map showing the fields to be used for the utilization of waste water.
Application of Waste by Irrigation
Field Soil Type Crop Application Application
No. Rate (In/Hr) Amount (In.)
1
To - CaB
Bermuda
0.6
.5 - 1.0
2
CaB
Bermuda
0.6
.5 - 1.0
THIS TABLE IS NOT NEEDED IF WASTE IS NOT BEING APPLIED BY IRRIGATION, HOWEVER A SIMILAR TABLE
WILL BE NEEDED FOR DRY LITTER OR SLURRY.
Your facility is designed for 180 days of temporary storage and the temporary storage
must be removed on the average of once every 6 MONTHS. In no instance should the volume
of waste being stored in your structure exceed Elevation *see lagoon staff gauges.
Call the local Natural Resources Conservation Service (formerly Soil Conservation Service) or
Soil and Water Conservation District office after you receive the waste analysis report for
assistance in determining the amount per acre to apply and the proper application rate prior to
applying the waste.
Narrative of operation: All land shown is irrigated with a hardhose traveller and dry hydrant
system. Grower has access to the "Aerwav" irriaation system and this is written into
the NUP. Subfield acres represents the difference between the total field acres and the wetted
acres. All fields will be in bermuda which will be cut for hay and they will be overseeded.
The bermuda rates have been grandfathered in from previous plans for this farm.
Page 4

..�� { �"I'�'1 r 1 s i ;;°`e?"4""("�` �i, �.: S . E•Kr.�t�e�reK;r�ttsenwn+�g n:<•rreds: r��ro+;.rwna�4 7" -"n.", a err` �{�'Y'7 , �'� w i? 4� '�q�� + S�Gv�
��-.�����'a L�����. `�:�WAS�T�E,�IJ,�TILIZ.i4T;10N+P,;1LAN ���;,�F�F, ,� ,, _� ,1{ k ,,E, � k 6♦ =�i{j�
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 . There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of waste, he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner of the facility to
secure an update, of the Waste Utilization Plan when there is a change in the operation,
increase in the number of animals, method of utilization, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climatic conditions, and level
of management, unless there are regulations that restrict the rate of application for other
nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but less than 10 tons per acre per
year providing grass filter strips are installed where runoff leaves the field. (See FOTG
Standard 393 - Filter Strip).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6 When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland,
the waste may be broadcast provided the application does not occur during a season
prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor or flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
Page 5

REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a
high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste
shall not be applied more than 30 days prior to planting of the crop or forages breaking
dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and from any perennial stream or river (other than an irrigation ditch or canal. Animal
waste other than swine waste from facilities sited on or after October 1, 1995), shall not be
applied closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips).
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site by a "technical specialist".
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that courses no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
Page 6

I .— I
.E..�,.'! � 7 t �,., •'�PY� �ya�Y � � {� '..°�r.T'r?�_'^ EyC*rm1�"i'�Tnt7R1'
f`f9"tTMt psi �ttP�iY, i1�P',' tt{`�i�"�,.,■ 1,/�-k �?{ J '����1Oi\3�f:iM�'taf �F���3 t SC1q,
tsi�4�....,diCv ar'1� 4 w radl uilR�lij�h %ex alY. Wb wa t rw. mw+ �_ n I •d I I �s§
REQUIRED SPECIFICATIONS
(continued)
17 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
18 Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
19 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied propellant with no further applications animal waste
during the crop season.
20 Highly visible markers shall be Installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
21 Waste shall be tested within 69 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste analysis records shall be kept
for five years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
22 Dead animals will be disposed of in a manner that meets North Carolina regulations.
Page 7

r, r
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: CC / Tomahawk Farm
Owner / Manager Agreement
I (we) understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. I (we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new facilities will require a new
certification to be submitted to the Division of Environment Management (DEM) before the
new animals are stocked. I (we) also understand that there must be no discharge of
animal waste from this system to surface waters of the state from a storm event less
severe than the 25-year, 24-hour storm. The approved plan will be filed on -site at the farm
office and at the office of the local Soil and Water Conservation District and will be
available for review by DEM upon request.
Name of Facility Owner: Murphy Farms, Inc.
(Please print)
Signature: l� Date: �` 30 ` 03
Name of Manager (If different from owner):
Signature: Date:
Name of Technical Specialist: (Pleaseprint) Ton! W. King
Affiliation: Murphy - Brown, LLC
Address (Agency): P.O. Box 856
Warsaw, NC 28398
Signature: Date: 0 3
Page 8

Al.
0!
ei
!6
'44i
X o
4 �j YT 519,
T41. r
3k x
1 J6
jj,,
W
2. 4�
A
.4. rd,
IL
IP
pl
7
1,7 if
"ot
0 co;,
:1
40
44
7.1 We I .
r4
qj
Ulu.
"4
37
ii.MV
N141
If,
�k
fg
-2,j" lr ;.,i. V,
, V-1
U1,
. " 4"e _Y4
Y,y
I 'jr>t r' I 7 ,

a
PRODUCER: CC / TOMAHAWK -- MURPHY FAMILY FARMS
LOCATION: 3361 CC ROAD; HARRELLS, NC 28444
TELEPHONE: (910) 532 - 4744
TYPE OPERATION: FEEDER - FINISH
NUMBER OF ANIMALS: 12,240
(Design Capacity)
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface and/or groundwater. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied. This waste utilization plan uses nitrogen as the limiting nutrient. Waste
should be analyzed before each application cycle. Annual soil tests are strongly encouraged
so that all plant nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and available water holding capacities. Normally waste shall not be applied to land
eroding at greater than 5 tons per acre per year. With special precautions, waste may be
applied to land eroding at up to 10 tons per year. Do not apply waste on saturated soils, when
it is raining, or when the surface is frozen. Either of these conditions may result in runoff to
surface waters which is not allowed under DEM regulations. Wind conditions should also be
considered to avoid drift and downwind odor problems. To maximize the value of nutrients for
crop production and to reduce the potential for pollution, the waste should be applied to a
growing crop or applied to bare ground not more than 30 days prior to planting. Injecting the
waste or disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for analysis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A
NCAC 2H.0217 adopted by the Environmental Management Commission.
Page 1

12,240 animals X 12 (tons) waste/animal/year =
Amount of Plant Available Nitrogen (PAN) Produced Per Year
12,240 animals X 2„3 lbs. PAN/animal/year =
Guide Std. 633)
23,256 (tons) waste/year.
28,152 lbs. PAN/year. (PAN from N.C.
Tech
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner
The following acreage will be needed for waste application based on the crop to be grown and
surface application:
Table 1: ACRES OWNED BY PRODUCER
Tract Field Soil Crop Lbs. N Acres Lbs, N Month of
# No. Type Per Acre Utilized Application
CC/TOM
1
To - CaB
Bermuda (G)
220
63.80
14,036
March - Oct
CC/TOM
2
CaB
Bermuda (G)
200
62.50
12,500
March -Oct
CC/TOM
2
To - CaB
Small Grain (G)
50
62.50
3,125
Sept -April
OPTIONAL"
1
CaB
Small Grain (G)
50
63.80
3,190
Sept - April
Total 1 126.30 1 29,661.00
*This N is from animal waste only. If nutrients from other sources such as commercial fertilizer are
applied, they must be accounted for. N must be based on realistic yield expectation.
NOTE: The applicator Is cautioned that P and K may be over applied while meeting the N
requirements. Beginning In 1996 the Coastal Zone Management Act will require farmers in some
eastern counties of North Caroline to have a nutrient management plan that addresses all nutrients.
This plan only addresses Nitrogen.
Page 2

Table 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowner must be attached)
(Required only If operator does not own adequate land [see
Required Specification 21)
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
` See footnote for Table 1.
Totals from above Tables
Acres Lbs. N
Utilized
Table 1 126.30Ei
Table 2
Total 126.30
Amount of N Produced
Surplus or Deficit
NOTE. The Waste Uditzatlon Plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to prevent over
application of nutrient or other elements.
Page 3

..< ';% tn..' x x i q:f;:< .•;;£f .% .=tM ..Y:,M,.. +�.'.�S'. ::ittii•:i�SYC '2.'S::f\'}:,:r$??F;.F:g:,�fifiitiErmxsr:i##.�:�k`?22:�\E:�2'.�r:Ekv.>Si.#`.`.:k's„t.}`S•`:;59`.t�••;
o . :s 4•:t � s: v .} :v . s' •' nr' :d�v�<ti"si.'%%� ..r. %}6 ;:i:'{:{ : •,".::: `� i.;•,):•, ,t2a'2:.2,r:•.:<ks�tV. 'S:r:i,}2s.b,:.E
kY•rx. ; .Y 1'a=.�i .2. 3k.c . ,,}}??��.{{YY9.F�n r.}i>t ''r � : 'G... :'�..., ::: it:; ..(..y: .:.; �5: .:.. ..:t,f�'S,:.ya.<�.y ;;.s.,,.y .,:,, 3,.,.:; .,
,2{ �,,..%,. .: � .. �.,2 ,v :r:r:22•?>:.2•.::. :.�,. :.2': k8 ' C4:,..,,?:. . r ., ...5..i:•.:2.,• :..,:.ry .:4: i::k}.n��;.ti;.:
> a,k•.2\j?;k. .�:. {� :.:�:^:. {��y��j+�,, .:..2:.:.,s.,.xt.;'.;:<:.x,:2;:x'''.2;:;.;2;.. .:.:....,:.,:.t,:a
,. 2..x..,.,iv.: w?x:2. e.n. •, .::�?. t .. �is1�i}i�' . d:3£ni+r;:.;:x... .. f..,........ c.. .,1. .
::}t'}r`tL:o•.2...:..:..::.....t.:..2.M...;S=....2.r:»;tr.:2:#}r;•,��.�',+���; �-- �: '.;.-. :..y:.:;:.:;:.
....,.,,,. .:. ...:.. ....,,,:..,.., ..,,....::..:..:., .: :...,...:,.:v.:.:..,.:,.,,,,,.,:..,.....,...:..,:.,..,..`.�:k�:::i2„7a'`:"`:'..:,..r..;.::.......;•.wn,::.,�r:?ttt«2ttt•::i252�h•r:?`<t�:...,:,.,,.r
See attached map showing the fields to be used for the utilization of waste water.
Application of Waste by Irrigation
Field Soil Type Crop Application Application
No. Rate lln/Hrl Amount (In.)
1
To - CaB
Bermuda
0.6
.5 -1.0
2
CaB
Bermuda
0.6
.5 - 1.0
THIS TABLE IS NOT NEEDED IF WASTE IS NOT BEING APPLIED BY IRRIGATION, HOWEVER A SIMILAR TABLE
WILL BE NEEDED FOR DRY LITTER OR SLURRY.
Your facility is designed for 180 days of temporary storage and the temporary storage
must be removed on the average of once every 6 MONTHS. in no instance should the
volume of waste being stored in your structure exceed Elevation "see lagoon staff gauges.
_Call the local Natural Resources Conservation Service (formerly Soil Conservation Service) or
Soil and Water Conservation District office after you receive the waste analysis report for
assistance in determining the amount per acre to apply and the proper application rate prior to
applying the waste.
Narrative of operation All land shown is irrigated with a hardhose traveller and dry hydrant
system. Grower is required to overseed a minimum of 60 acres in small grain each year, but
may overseed all as long as rates and timing shown are used, All land may be grazed.
Page 4

REQUIRED SPECIFICATIONS
1 Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of waste, he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing him/her the
use of the land for waste application. it is the responsibility of the owner of the facility to
secure an update of the Waste Utilization Plan when there is a change in the operation,
increase in the number of animals, method of utilization, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climatic conditions, and level
of management, unless there are regulations that restrict the rate of application for other
nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but less than 10 tons per acre per
year providing grass filter strips are installed where runoff leaves the field. (See FOTG
Standard 393 - Filter Strip).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6 When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland,
the waste may be broadcast provided the application does not occur during a season
prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor or flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
Page 5

f •< } ri s� j'P -" ►W"3i .tl� i ? ii'. �?hk• i aPtl(y6Y••� y�a. �'AM13 �¢I�ei ItFF
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a
high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste
shall not be applied more than 30 days prior to planting of the crop or forages breaking
dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and from any perennial stream or river (other than an irrigation ditch or canal. Animal
waste other than swine waste from facilities sited on or after October 1, 1995), shall not be
applied closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips).
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site by a "technical specialist".
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
Page 6

REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced as necessary to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied pre -plant with no further applications animal waste
during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Sal and waste analysis records shall be kept
for five years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
23
Dead animals will be disposed of in a manner that meets North Carolina regulations.
Page 7

Name of Farm: CC 1 Tomahawk Farm
Owner/ Manager Agreement
I (we) understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. l (we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new facilities will require a new
certification to be submitted to the Division of Environment Management (DEM) before
the new animals are stocked. I (we) also understand that there must be no discharge of
animal waste from this system to surface waters of the state from a storm event less
severe than the 25-year, 24-hour storm. The approved plan will be filed on -site at the
farm office and at the office of the local Soil and Water Conservation District and will be
available for review by DEM upon request.
Name of Facility Owner: Murphy Farms, Inc.
*Waase print) ,ti
Signature: e e �� Date:
Name of M qer (If diffnt frambLvner):�,t�
Signature: . Date: c7
Name of Technical Specialist: (Please print) Ton! W. King
Affiliation: Murphy - Brown, LLC
Address (Agency): P.O. Box 856
Warsaw, NC 28398
Slgnatur Date: CD—aqj_ C�-2_
Page 8

44,b J '✓ '
3
Y3
i•Yf
$'7 4
�o r.qa
f 7.6q
t 74?
4•Qf
s' �4
fit
�1
•T
�
�
v
`i

k,
cl
1E •
Ei
.15gp J,,",T I 1 •a .
� e•Y�
� Asa
5
Lf59
to r.qa
t t �•��
t tv 09
7 4
ti

. icrr��rnrtcv� ."
5,3�. ►� !3 s.s1
t
® U �
r
5.3'f 3.09
� LL
f V
0
s•3�{ $
� �•s�
h
a
�
.
S' ZA 5
z• �I z
Mo
y..,-
a 3 •
3 $a
t
Lo�) / 1.
..S"3
»
•"S.3
h Q
S" S• 3
c)
�.--
�' s•sY
S. 5. n R
.�, io
i'q. 6 r
U

s� 8,; Wp►TE�JTILI7ATION PLAN
LOCATION: 3361 CC ROAD; HARRELLS, NC 28444
TELEPHONE: (910) 532 - 4744
TYPE OPERATION: FEEDER - FINISH
NUMBER OF ANIMALS: 12,240
(Design Capacity)
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface and/or groundwater. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops in the fields where the waste is
to be applied. This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle. Annual soil tests are strongly encouraged so that all
plant nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and available water holding capacities. Normally waste shall not be applied to land
eroding at greater than 5 tons per acre per year. With special precautions, waste may be
applied to land eroding at up to 10 tons per year. Do not apply waste on saturated soils, when it
is raining, or when the surface is frozen. Either of these conditions may result in runoff to
surface waters which is not allowed under DEM regulations. Wind conditions should also be
considered to avoid drift and downwind odor problems. To maximize the value of nutrients for
crop production and to reduce the potential for pollution, the waste should be applied to a
growing crop or applied to bare ground not more than 30 days prior to planting. Injecting the
waste or disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for analysis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
21-1.0217 adopted by the Environmental Management Commission.
RECEIVED !DENR1DWQ
AQUIEFR-PRnTFrT'0N SECTION
Page 1
APR 0 6 7004

Amount of Waste Produced Per Year (gallons, ft. tons, etc.)
12,240 animals X 1_9 (tons) waste/animal/year = 23,256 (tons) waste/year.
Amount of Plant Available Nitrogen (PAN) Produced Per Year
12,240 animals X 223 lids. PAN/animal/year = 28,152 lbs. PAN/year. (PAN from N.C.
Guide Std. 633) Tech
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner
The following acreage will be needed for waste application based on the crop to be grown and
surface application:
Table 1: ACRES OWNED BY PRODUCER
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
# No. Type Per Acre Utilized Application
CCITOM
1
To/CaB/LeA
Bermuda G
220
48.43
10,655
March - Sept
CCITOM
2
CaB
Bermuda G
200
41.66
8,332
March - Seet
all
Small Grain
50
90.09
4,505
Sept - April
CCITOM
subfield 1
ToICaBILeA
Bermuda G
220
15.37
3,381
March - Sept
CC/TOM
subfield 2
CaB
Bermuda G
200
20.84
4,168
March - Sept
all
Small Grain
50
36,21
1,811
Sept - April
Total I 126.30 132.8 51.00
*This N is from animal waste only. If nutrients from other sources such as commercial fertilizer are
applied, they must be accounted for. N must be based on realistic yield expectation.
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N
requirements. Beginning in 1996 the Coastal Zone Management Act will require farmers in some
eastern counties of North Caroline to have a nutrient management plan that addresses all nutrients.
This plan only addresses Nitrogen.
Page 2

Table 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowner must be attached)
(Required only If operator does not own adequate land [see
Required Specification 21)
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
ApplicationNo. Type Per Acre* Utilized
* See footnote for Table 1
Totals from above Tables
Acres Lbs. N
Utilized
Table 1 12fi.3a 32,851
Table 2
Total 126.30 32,851
Amount of N Produced 28,152
Surplus or Deficit 4,699
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to prevent over
application of nutrient or other elements.
Page 3

See attached map showing the fields to be used for the utilization of waste water.
Application of Waste by Irrigation
Field Soil Type Crop Application Application
No. Rate (IniHr) Amount (In.)
1
To - CaB
Bermuda
0.6
.5 -1.0
2
CaB
Bermuda
0.6
.5 -1.0
THIS TABLE IS NOT NEEDED IF WASTE IS NOT BEING APPLIED BY IRRIGATION, HOWEVER A SIMILAR TABLE
WILL BE NEEDED FOR DRY LITTER OR SLURRY.
Your facility is designed for 180 days of temporary storage and the temporary storage
must be removed on the average of once every 6 MONTHS. In no instance should the volume
of waste being stored in your structure exceed Elevation `see la -goon staff gauges.
Call the local Natural Resources Conservation Service (formerly Soil Conservation Service) or
Soil and Water Conservation District office after you receive the waste analysis report for
assistance in determining the amount per acre to apply and the proper application rate prior to
applying the waste.
Narrative of operation: All land shown is irrigated with a hardhose traveller and dry hydrant
system. Grower has access to the "Aerwav" irrigation system and this is written into
the NUP. Subfield acres represents the difference between the total field acres and the wetted
acres. All fields will be in bermuda which will be cut for hay and they will be overseeded.
The bermuda rates have been grandfathered in from previous plans for this farm.
Page 4

REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of waste, he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing himyher the
use of the land for waste application. It is the responsibility of the owner of the facility to
secure an update of the Waste Utilization Plan when there is a change in the operation,
increase in the number of animals, method of utilization, or available land.
Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climatic conditions, and level
of management, unless there are regulations that restrict the rate of application for other
nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but less than 10 tons per acre per
year providing grass filter strips are installed where runoff leaves the field. (See FOTG
Standard 393 - Filter Strip).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6 When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland,
the waste may be broadcast provided the application does not occur during a season
prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor or flies.
Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
Page 5

REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a
high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste
shall not be applied more than 30 days prior to planting of the crop or forages breaking
dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and from any perennial stream or river (other than an irrigation ditch or canal. Animal
waste other than swine waste from facilities sited on or after October 1, 1995), shall not be
applied closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips).
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site by a "technical specialist".
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that courses no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
Page 6

IIVASTE .IJ�TI LIOAT101VPLAN
REQUIRED SPECIFICATIONS
(continued)
17 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
18 Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
19 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied propellant with no further applications animal waste
during the crop season.
20 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid.level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
21 Waste shall be tested within 69 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels, pH shall be adjusted for
optimum crop production and maintained. Soil and waste analysis records shall be kept
for five years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
22 Dead animals will be disposed of in a manner that meets North Carolina regulations.
Page 7

WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: CC / Tomahawk Farm
Owner / Manager Agreement
I (we) understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. I (we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new facilities will require a new
certification to be submitted to the Division of Environment Management (OEM) before
the new animals are stocked. I (we) also understand that there must be no discharge of
animal waste from this system to surface waters of the state from a storm event less
severe than the 25-year, 24-hour storm. The approved plan will be filed on -site at the
farm office and at the office of the local Soil and Water Conservation District and will be
available for review by DEM upon request.
Name of Facility Owner: Murphy Farms, Inc.
(Please print)
Signature:
Name of Manager (If different from owner)
Signature:
Date:
Richard Smith
Date:
Name of Technical Specialist: (Please print) Toni W. King
Affiliation: Murphy - Brown, LLC
Address (Agency):
Signature:
P.O. Box 856
Warsaw, NC 26396
Date:
Page 8

�QF W A r4RP - Michael F. Easley, Governor
4 ` .N"' n:
t'i ���� � i�v � William G. Ross Jr., Secretary
co k North Carolina Department of Environment and Natural Resources
.� AUG., a 3 2 Coleen H. Sullins Director
Division of Water Quality
l
August 11, 2008
Murphy -Brown, LLC
CC/Tomahawk Farm
PO Box 1139
Wallace, NC 28466
Subject: Sludge Compliance Requirement Change
Dear Permittee:
In accordance with Condition I1I.19 of State General Permit AWG100000, your facility is
required to maintain compliance regarding sludge accumulation in your animal waste treatment
lagoon(s). As you know, the previous compliance limit was to have a minimum of four (4) feet
of treatment depth between the designed stop pump and the average elevation of the top of the
sludge blanket. This requirement was based on NRCS Standard No. 359, which was recently
modified.
As of July 2008, Standard No. 359 does not use the 4-foot requirement. Sludge compliance is
now to be based on the sludge volume as a percentage of the total treatment volume. The revised
Standard states that sludge accumulation in the permanent treatment zone must be less than 50%
of the planned treatment volume. Also, there must be a minimum of 2.5 feet of liquid above the
sludge at the pump intake location. If either of these conditions is not met then sludge must be
removed or managed in accordance with an approved Plan of Action for Lagoon Sludge
Reduction (POA). A new sludge survey worksheet has been developed to calculate sludge and
treatment volumes to determine compliance.
Our records indicate that you have filed a Sludge POA for one or more of the lagoons at your
facility. Based on -the changes to the sludge requirements in Standard No. 359, your lagoon(s)
may already be in compliance without any sludge removal. Using your lagoon design (or as -
built information) and current sludge survey measurements, complete the NEW sludge survey
worksheet. If you have any difficulty in locating or understanding your lagoon design
information, please contact your technical specialist or county Soil & Water office.
N'p"` hCarolina
Natirrally
Aquifer Protection Section 1636 Mail Service Center Raleigh, NC 27699-1636 Telephone: [phone]
Internet: www.ncwatMjyalitv.org Location: 2728 Capital Boulevard Raleigh, NC 27604 Fax 1: [phone]
Fax 2: [phone]
An Equal Opportun4lAtfirmative Action Employer- 50% Recycled110% Post Consumer Paper

i
C—
Send both sludge survey worksheets, OLD and NEW, to the address below if you feel that your
lagoon(s) is in compliance and wish to withdraw your POA. Our staff will review the
information and notify you of our decision.
NCDENR — DWQ Animal Feeding Operations Unit
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
If you have any questions about the new sludge requirement, sludge survey worksheet, or any
related matter please feel free to contact the Animal Feeding Operations Unit staff at 919-733-
3221.
Sincerely,
1141' &-� �-
Keith Larick, Supervisor
Animal Feeding Operations Unit
Enclosures
cc (w/o enclosures): Sampson County Soil and Water Conservation District
Fayetteville Regional Office, Aquifer Protection Section
AFO Unit Central Files - AWS820030

W A
7 �
Michael F. Easley. Governor
William G. Ross Jr.. Secretary
North Carolina Department of Environment and Natural Resources
Coleen H. Sullins. Director
Division of Water Quality
July 1, 2007
Murphy -Brown, LLC UN 2 7 c0L7
CC/Tomahawk Farm
PO Box 856
Warsaw, NC 28398
Subject: Certificate of Coverage No. AWS820030
CC/Tomahawk Farm
Animal Waste Management System
Sampson County
Dear Murphy -Brown, LLC:
In accordance with your application received on II-Jun-07, we are hereby forwarding to you this
Certificate of Coverage (COC) issued to Murphy -Brown, LLC, authorizing the operation of the subject
animal waste management system in accordance with General Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for the CC/Tomahawk Farm, located in Sampson County, with an animal capacity of no
greater than the following swine annual averages:
Wean to Finish: 0 Feeder to Finish: 12240 Boar/Stud: 0
Wean to Feeder: 0 Farrow to Wean: 0 Gilts: 0
Farrow to Finish: 0 Farrow to Feeder: 0
If this is a Farrow to Wean or Farrow to Feeder operation, there may also be one boar for each 15 sows.
Where boars are unneccessary, they may be replaced by an equivalent number of sows. Any of the sows
may be replaced by gilts at a rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009 and replaces the NPDES
COC issued to this facility with an expiration date of July 1, 2007. You are required to continue
conducting annual surveys of sludge accumulation in all lagoons at your facility; the one-year extension
in Condition III.19 does not apply.
Pursuant to this COC, you are authorized and required to operate the system in conformity with the
conditions and limitations as specified in the General Permit, the facility's CAWMP, and this COC. An
adequate system for collecting and maintaining the required monitoring data and operational information
must be established for this facility. Any increase in waste production greater than the certified design
capacity or increase in number of animals authorized by this COC (as provided above) will require a
modification to the CAWMP and this COC and must be completed prior to actual increase in either
wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Enclosed for your convenience is
a package containing the new and revised forms used for record keeping and reporting. Please_pay
careful attention to the record keeping and monitoring conditions in this permit.
Aquifer Protection Section 1636 Mail Service Center
Internet: www.ncwatmgunliiy.org Location: 2728 Capital Boulevard
An Equal Opportunity/Affirmative Action Employer— 509% Recyded110% Post Consumer Paper
Nam` Caru ina
Naturally
Raleigh, NC 27699-1636 Telephone: [phone]
Raleigh, NC 27604 Fax 1: [phone]
Fax 2: [phone]
Customer Service: [phone]

If your Waste Utilization Plan has been developed based on site -specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 02T .01 I I(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100-foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Per 15A NCAC 02T .1306, any containment basin, such as a lagoon or waste storage structure, shall
continue to be subject to the conditions and requirements of the facility's permit until closed to NRCS
standards and the permit is rescinded by the Division.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Aquifer Protection staff may be reached at 910-433-3300. If you need additional information concerning
this COC or the General Permit, please contact the Animal Feeding Operations Unit staff at (919) 733-
3221.
Sincerely,
L
for Coleen H. Sullins
Enclosures (General Permit AWG100000, Record Keeping and Reporting Package)
cc: (Certificate of Coverage only for all cc's)
Sampson County Health Department
Sampson County Soil and Water Conservation District
Fayetteville Regional Office, Aquifer Protection Section
AFO Unit Central Files
Permit File AWS820030

LIC
PRODUCER: CC 1 TOMAHAWK -- MURPHY FAMILY FARMS
LOCATION: 3361 CC ROAD; HARRELLS, NC 28444
TELEPHONE: (910) 532 - 4744
TYPE OPERATION: FEEDER - FINISH
NUMBER OF ANIMALS: 12,240
(Design Capacity)
RECEIVED 1 DENR 1 DWQ
AQUIFFR'PRCTFCTION SECTION
DEC 2 7 2006.
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface and/or groundwater. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops in the fields where the waste is
to be applied. This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle. Annual soil tests are strongly encouraged so that all
plant nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied In an environmentally safe
manner. Always apply waste based on the needs of the crop. to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and available water holding capacities. Normally waste shall not be applied to land
eroding at greater than 5 tons per acre per year. With special precautions, waste may be
applied to land eroding at up to 10 tons per year. Do not apply waste on saturated soils, when it
is raining, or when the surface is frozen. Either of these conditions may result in runoff to
surface waters which is not allowed under DEM regulations. Wind conditions should also be
considered to avold drift and downwind odor problems. To maximize the value of nutrients for
crop production and to reduce the potential for pollution, the waste should be applied to a
growing crop or applied to bare ground not more than 30 days prior to planting. Injecting the
waste or disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for analysis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2� ti+•Dpted'Ltry t -E eoiprimental Management Commission.
JAN 0 0 2007
Page 1
DENR-4AYET UEALLE REGIONAL OFPCE

Amount of Waste Produced Per Year (gallons, Ft, tons, etc.)
12,240 animals X 1.9 (tons) wastelanlmal/year = 23,256 (tons) waste/year.
Amount of Plant Available Nitrogen (PAN) Produced Per Year
12,240 animals X 2_3 lbs. PAN/animal/year 28,152 lbs. PAN/year. (PAN from N.C.
Guide Std. 633) Tech
Applying .the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner
The following acreage will be needed for waste application based on the crop to be grown and
surface application:
Table 1: ACRES OWNED BY PRODUCER
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
# No. Type Per Acre Utilized Application
CC/TOM
1
To/CaBILeA
Bermuda G
2201
48.43
10,655
March - Sept
CC/TOM
2
CaB
Bermuda G
2001
41.66
8,332
March - Sept
all
Small Grain
501
90.09
4,505
Sept - April
CCITOM
subfield 1
ToICaB/LeA
Bermuda G
220
15.37
3,381
March - Sept
CC/TOM
subfleld 2
CaB
Bermuda G
200
20.84
4,168
March - Se t
all
Small Grain
50
36.21
1,811
Sept - April
Total 1 125.3u l 32,851.00 1
'This N is from animal waste only. If nutrients from other sources such as commercial fertilizer are
applied, they must be accounted for. N must be based on realistic yield expectation.
NOTE: The applicator Is cautioned that P and K may be over applied while meeting the N
requirements. Beginning In 1996 the Coastal Zone Management Act will require farmers In some
eastern counties of North Caroline to have a nutrient management plan that addresses all nutrients.
This plan only addresses Nitrogen.
Page 2

Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
# No. Type Per Acre* Utilized Application
" See footnote for Table 1.
Totals from above Tables
Acres Lbs. N
Utilized
Table 1 126.301 32,851
Table 2
Total 126.30 32,851
Amount of N Produced 28,152
Surplus or Deficit (4,699)1
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to prevent over
application of nutrient or other elements.
Page 3

See attached map showing the fields to be used for the utilization of waste water.
Application of Waste by Irrigation
Field Soil Type Crop Application Application
No. Rate In1Hr Amount In.
1
To - CaB
Bermuda
0.6
.5 - 1.0
2
CaB
Bermuda
0.6
.5 - 1.0
THIS TABLE IS NOT NEEDED IF WASTE IS NOT BEING APPLIED BY IRRIGATION, HOWEVER A SIMILAR TABLE
WILL BE NEEDED FOR DRY LITTER OR SLURRY.
Your facility is designed for 180 days of temporary storage and the temporary storage
must be removed on the average of once every 6 MONTHS. In no instance should the volume
of waste being stored in your structure exceed Elevation 'see lagoon staff gauges.
Call the local Natural Resources Conservation Service (formerly Soil Conservation Service) or
Soil and Water Conservation District office after you receive the waste analysis report for
assistance in determining the amount per acre to apply and the proper application rate prior to
applying the waste,
!Narrative of operation: All land shown Is irrigated with a hardhose traveller and dry hydrant
system. Grower has access to the "Aerwav" Irrigation system and this Is written Into
the NUP. Subfield acre_ s represents the difference between the total field acres and the wetted
acres. All fields will be in bermuda which will be cut for hay and they will be overseeded.
The bermuda rates have been grandfathered In from previous plans for this farm.
Page 4

REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the slate by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of waste, he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner of the facility to
secure an update of the Waste Utilization Plan when there is a change in the operation,
increase in the number of animals, method of utilization, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climatic conditions, and level
of management, unless there are regulations that restrict the rate of application for other
nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but less than 16 tons per acre per
year providing grass filter strips are installed where runoff leaves the field. (See l=OTG
Standard 393 - Filter Strip).
Odors can be reduced by Injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
6 When animal waste Is to be applied on acres subject to Flooding, it will be soil Incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland,
the waste may be broadcast provided the application does not occur during a season
prone to flooding. (See "Weather and Climate In North Carolina" for guidance.)
7 Liquid waste shall be applied at rates not to exceed the soil Infiltration rate such that runoff
does not occur offsite or to surface waters and In a method which does not cause drift
from the site during application. No ponding should occur In order to control odor or flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
Page 5

4 b•-'• '
�S'Ah�}'�: 1!{: -.i�r 5,���;:• ;N,, .�l,�. �� .'C-865l.-��JT� .'�—,1iLic�} i.'��Yn..e ..,N,{
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a
high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste
shall not be applied more than 30 days prior to planting of the crop or forages breaking
dormancy:
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that Is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and from any perennial stream or river (other than an irrigation ditch or canal. Animal
waste other than swine waste from facilities sited on or after October 1, 1995), shall not be
applied closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips).
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site by a "technical specialist".
Animal waste shall not be applied on grassed waterways that discharge directly Into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates In a
manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
Page 6

ls,.��Y-��'. .t����71! A �w,,,lP•.J� �' F r. ����ti" � :t�;1�{� w�i�3
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced as necessary to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied pre -plant with no further applications animal waste
during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Solt and waste analysis records shall be kept
for five years. Poultry dry waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be maintained for five (5) years.
23
Dead animals will be disposed of in a manner that meets North Carolina regulations.
Page 7

WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: CC / Tomahawk Farm
Owner / Manager Agreement
I (we) understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. i (we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new facilities will require a new
certification to be submitted to the Division of Environment Management (DEM) before the
new animals are stocked. I (we) also understand that there must be no discharge of
animal waste from this system to surface waters of the state from a storm event less
severe than the 25-year, 24-hour storm. The approved plan will be filed on -site at the farm
office and at the office of the local Soil and Water Conservation District and will be
available for review by DEM upon request.
Name of Facility Owner: Murphy Farms, Inc.
(Please print)
Signature: Date: U — <:L
Name of Manager (if different from owner): Richard Smith
Signature: ~� Date:
Name of Technical Specialist: (Please print) Toni W. King
Affiliation: Murphy - Brown, LLC
Address (Agency): P.O. Box 656
Warsaw, NC 28356
Signature: r w Date: �9'
Page 8

December 1, 2006
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Murphy Farms LLC
CC/Tomahawk Farm
PO Box 759
Rose Hill, NC 28458
Michael F. Easley. Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Subject: Application for Renewal of Coverage for Expiring NPDES General Permit
Dear Permittee:
Alan W. Klimek, P.H. Director
Division of Water Quality
RECEIVED
DEC 06 2M
ON-FAYEFI MUF OMLOWE
Your facility is currently approved for operation under one of the Animal Waste Operation NPDES General Permits, which expire on
July 1, 2007, Due to changes in federal rules, facilities that do not discharge nor propose to discharge may choose whether or not to
retain coverage under an NPDES General Permit. Copies of the draft animal waste operation NPDES general permits and the State
Non -Discharge General Permits are available at htip://h2o.enr.state.ne.us/al2s/afou/downtoads,htm or by writing or calling:
NCDENR — DWQ Animal Feeding Operations Unit
1636 Mail Service Center
Raieigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure your continued coverage under one of these two types of general permits, you must submit an application for permit
coverage to the Division. Enclosed you will find a 'Request for Certificate of Coverage Facility Currently Covered by an Expiring
NPDES General Permit.' The application form must be completed and returned by January 2, 2007. Please note, You must include
two (2) copies of your most recent Waste Utilization Plan with the application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the draft general permits, the enclosed application, or any related matter please feel free to contact the
Animal Feeding Operations Unit staff at 919-733-3221.
Sincerely,
Ted L. Bush, Jr., Chief
Aquifer Protection Section
Enclosures
cc (w/o enclosures): Sampson County Soil and Water Conservation District
Fayetteville Regional Office, Aquifer Protection Section
AFO Unit Central Files - 820030
Murphy Family Farms
Aquifer Protection Section 1636 Mail Service Center Raleigh, NC 27699-1636
Internet: www.ncwaterquaiity,org Location: 2728 Capital Boulevard Raleigh, NC 27604
An Equal OpportunitylAffirmative Action Employer— 50% Recycled l0% Post Consumer Paper
Telephone:
Fax l:
Fax 2:
Customer Service:
4',�` Carolina
(919) ✓vaiurdl4l
[phone]
[phone]
[phone]

Environmental
Quality
Hot Dog Farms, LLC
Hot Dog Farms
P. O. Box 535
Elizabethtown, NC 28337
Dear Hot Dog Farms, LLC:
REGEivtD
DEQiDVVR
019
WQROS
AYETT%§ 5,RHp§)NAI- OFFICE
ROY COOPER
Governor
MICHAEL S. REGAN
Secretary
LiNDA CULPEPPER
Interim Director
Subject: Certificate of Coverage No. AWS820030
Hot Dog Farms
Swine Waste Collection, Treatment,
Storage and Application System
Sampson County
In accordance with your April 30, 2018 Notification of Change of Ownership, we are hereby forwarding to
you this Certificate of Coverage (COC) issued to Hot Dog Farms, LLC, authorizing the operation of the
subject animal waste management system in accordance with General Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management Plan
(CAWMP) for Hot Dog Farms, located in Sampson County, with a swine animal capacity of no greater
than the following annual averages:
Wean to Finish: Feeder to Finish: 12,240 Boar/Stud:
Wean to Feeder: Farrow to Wean: Gilts:
Farrow to Finish: Farrow to Feeder: Other:
If this is a Farrow to Wean or Farrow to Feeder operation, there may be one boar for each 15 sows. Where
boars are unnecessary, they may be replaced by an equivalent number of sows. Any of the sows may be
replaced by gilts at a rate of 4 gilts for every 3 sows.
This COC shall be effective from the date of issuance until September 30, 2019, and shall hereby void
Certificate of Coverage Number AWS820030 dated October 1, 2014. Pursuant to this COC, you are
authorized and required to operate the system in conformity with the conditions and limitations as specified
in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting and
maintaining the required monitoring data and operational information must be established for this facility.
Any increase in waste production greater than the certified design capacity or increase in number of animals
authorized by this COC (as provided above) will require a modification to the CAWMP and this COC and
must be completed prior to actual increase in either wastewater flow or number of animals.
Please read this COC and the enclosed State General Permit carefully. Please 12ay careful attention to the
record keeping and monitoring conditions in this permit. Record keeping forms are unchanged with this
General Permit. Please continue to use the same record keeping forms.
Stale of North Carolina j i_nvironmental Quality I Division of Water Resources
Water Quality Regional Operations Section
1636 (Nail Service Center I Raleigh, North Carolina 27699-1636
919-707-9129

If your Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Per NRCS standards a 100-foot separation shall be maintained between water supply wells and any lagoon,
storage pond, or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Program for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition II.22 of the General Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Tropical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You may
find detailed watch/warning information for your county by calling the Raleigh, NC National Weather
Service office at [phone], or by visiting their website at: httn.://www.weather,gov/rail/
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office staff
may be reached at 919433-3300. If you need additional information concerning this COC or the General
Permit, please contact the Animal Feeding Operations Program staff at [phone].
Sincerely,
6b, W
Linda Culpepper
Interim Director, Division of Water Resources
Enclosure (General Permit AWG100000)
cc: (Certificate of Coverage only for all ccs)
Fayetteville Regional Office, Water Quality Regional Operations Section
Sampson County Health Department
Sampson County Soil and Water Conservation District
WQROS Central Files (Permit No. AWS820030)
Smithfield Hog Production