780087_CORRESPONDENCE_20171231

NUH I H UAHULINA
Department of Environmental Qual

'4�A
NCDENR
North Carolina Department of Environment and Natural
Pat McCrory
Governor
Eddie Johnson
Eddie Johnson #2
905 White Pond Road, West
Fairmont, NC 28340
Dear Eddie Johnson:
September 26, 2014
RECEIVED
�r���eSggEP 3 0 2014
PMRO-FaYtTfEMLLEREGIONAL OFnCF
John E. Skvada, III
Secretary
Subject: Sludge Survey Testing Dates
Certificate of Coverage No. AWS780087
Eddie Johnson #2
Animal Waste Management System
Robeson County
The Division of Water Resources (Division) received your sludge survey information on
September 23, 2014. With the survey results, you requested an extension of the sludge survey
requirement for the lagoon at the Eddie Johnson #2 facility. Due to the amount of treatment
volume available, and the rate of sludge accumulation for the lagoon, the Division feels that the
next sludge survey at 4iis facility should be performed before December 31, 2020.
Please retain this letter and keep it with your farm records for reference. Thank you for your
attention to this matter.
Please call me at [phone] if you have any questions.
Sincerely,
Miressa D. Garoma
Animal Feeding Operations Program
Water Quality Regional Operations Section
Division of Water Resources, NCDENR
cc: Fayetteville Regional Office, Water Quality Regional Operations Section
Permit File AWS780087
1636 Mail Service Center, Raleigh, North Carolina 27699-1636
Phone:91M07-64641Internet: http.:Ilwww.nodenr.gov/
An Equal Opportunity ti Affirmative Action Employer — Made in part by recycled paper

A19";'A
MCDEN
North Carolina Department of Environment and Natural Resources Dwo
Division of Water Quality
Beverly saves Perdue Coleen H. Sullins Dee Freeman
Governor Director Secretary
August 29.2011
Eddie Johnson
Eddie Johnson Farm
905 White Pond Rd W
Fairmont, NC 28340
Subject: Sludge Survey Testing Dates
Certificate of Coverage No. AWS780087
Eddie Johnson #2
Animal Waste Management System
Robeson County
Dear Eddie Johnson:
The Division of Water Quality (Division) received your sludge survey information on August 1,
zn
2011. With the survey results, you requested an extension of the sludge survey requirement for
the lagoon at Eddie Johnson #2. Due to the amount of treatment volume available, the Division
agrees that a sludge survey is not needed until 2014.
The next sludge survey at this facility should be performed before December 31, 2014. Thank
you for your attention to this matter. Please tail me at [phone] if you have any questions.
Sincerely,
W�&V
Miressa D. Garoma
Animal Feeding Operations unit
CC" Fayetteville Regional Office; Aquifer Protection Section
Permit File AWS780087
1636 Mail 5ervie=_ °shier. Raieiar.. Nortn Carolina 27;=y-1c3;,
Laoatnn: 2?29'IaDital l ivd., Rale!al. NON. Carolina "760"
Pmrt=: 91 733-3221 =,X. 9 i ti %'; GSae + uslorner service
ante.ma--: wvm.navarereua:: ry.ore
0f"-
NortiiCamlina

NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins Dee Freeman
Governor Director Secretary
July 17, 2009
Eddie L. Johnson
Eddie Johnson #2
905 White Pond Rd West
Fairmont, NC 28340
RECEIVED
AIL 21 M.
OW - FAYETRLLE REGIONAL OFRCE
Subject: Sludge Survey Testing Dates
Certificate of Coverage No. AWS780087
Eddie Johnson 42
Animal Waste Management System
Robeson County
Dear Eddie Johnson:
The Division. of Water Quality (Division) received your sludge survey information on July 2, ,
2009; With the survey results, you requested an extension of the sludge survey requirement for
the lagoon at the Eddie Johnson #2 facility. Due to the amounts of treatment volume available,
the Division agrees that a sludge survey is not needed until 2012.
Thank you for your attention to this matter. if you have any questions, please call me at (919).
715-6937.
Si
ncerely,
Miressa D. Garoma
Animal Feeding Operations Unit
cc: Fayetteville Regional Office, Aquifer Protection Section
Central Files
1617 flail Szc vice Center. Raleip. North Carolina 27699-1617
Loeatior: 512 N. Salisbury St. Raleigh. North Carolina 27604 T�TOne
Phone: [phone]V FAX: [phone] Custamer Service: 1-877-62U748 � V orthCaro 1 ila
Internet: rrsvw.nmalerquaiily.arg �'��������r/�.
n equal i1 awnaiP; ma!itGRcHo�r Griplcyer ll

PRODUCER:
LOCATION:
TELEPHONE:
TYPE OPERATION:
Johnson Farms #2
905 White Pond Rd. West
Fairmont, NC 28340
[phone]
wean - feeder
NUMBER OF ANIMALS: 3552
(Design Capacity)
RECEIVED - -
APR 0 6 2M
�-IiQYE1Tl�illr ll.
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface and/or groundwater. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied. This waste utilization plan uses nitrogen as the limiting nutrient. Waste
should be analyzed before each application cycle. Annual soil tests are strongly encouraged
so that all plant nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and available water holding capacities. Normally waste shall not be applied to land
eroding at greater than 5 tons per acre per year. With special precautions, waste may be
applied to land eroding at up to 10 tons per year. Do not apply waste on saturated soils, when
it is raining, or when the surface is frozen. Either of these conditions may result in runoff to
surface waters which is not allowed under DEM regulations. Wind conditions should also be
considered to avoid drift and downwind odor problems_ To maximize the value of nutrients for
crop production and to reduce the potential for pollution, the waste should be applied to a
growing crop or applied to bare ground not more than 30 days prior to planting. Injecting the
waste or disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for analysis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A
NCAC 21-1.0217 adopted by the Environmental Management Commission.
Page 1

r t WASTE -UTI-LIZATIQN PLAN y x
3.552 animals X 0.42 (tons) wastelanimallyear =
Amount of Plant Available Nitrogen (PAN) Produced Per Year
3,552 animals X QA$ lbs. PANlanimallyear =
Guide Std. 633)
1,492 (tons) waste/year.
1,705 lbs. PAN/year. (PAN from N.C.
Tech
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner
The following acreage will be needed for waste application based on the crop to be grown and
surface application:
Table 1- ACRES OWNED BY PRODUCER
Tract Field* Soil Crop Lbs. N Acres Lbs. N Month of
# No. Type Per Acre Utilized Application
T4069
1
NoA
Bermuda(H)
305
5.30
1616.5
March - Sept.
T4069
2
Ra
Bermuda(H)
225
6.42
1444.5
March - Sept.
Optional
T4069
1,2
NA
Small Grain
50
11.72
586
Sept. - April
Optional
T4069
3
NoA
Com
137
8.36
1145.32
March - July
T4069
3
NoA
Wheat
120
8.36
1003.2
Sept. - April
T4069
3
NoA
Soybeans
110
8.36
919.6
June - Sept.
T4069
4
NoA
Com
137
6.78
928.86
March - July
T4069
4
NoA
Wheat
120
6.78
813.6
Sept. - April
T4069
4
NoA
Soybeans
110
6.78
745.8
June - Sept.
Total 11-721 3,061.00
*This N is from animal waste only, if nutrients from other sources such as commercial fertilizer are
applied, they must be accounted for. N must be based on realistic yield McCtation_.
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N
requirements. Beginning in 1996 the Coastal Zone Management Act will require farmers in some
eastern counties of North Caroline to have a nutrient management plan that addresses all nutrients.
This plan only addresses Nitrogen.
Page 2

�Y �11VASTE �lT�LtL4TiON PLAN 5 � Y
Table 2. ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowner must be attached)
(Required only if operator does not own adequate land [see
Required Specification 21)
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
# No. Type Per Acre* Utilized Application
. See footnote for Table 1 _
Total -
Totals from above Tables
Acres Lbs. N
Utilized
Table 1
11.72
3,061
Table 2
0.00
-
Total
11.72
3,061
Amount of N Produced
1,705
Surplus or Deficit
(1,356)
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to prevent over
application of nutrient or other elements.
Page 3

f.,h y Qr h'y h'L"i`3:- ri-.::e?e5'"vr ;•ti.�aComy�'«w. .new. .u. 75= -^A'�o:Sv�rot>:c+c.:s:.'+v ud-.� -- - cam.,, '"'Y 'y�. -- _�^� r„^^^^'�`: ,.-�"c-,.... h�k.. -< ---
:eK:Y r1r:' �:rY x � � n R"�`�^'' ' 'r5' ,Y>t,,,c, c • 'v - � : �.t,
r..',kt � tip: �J r'�� 'v+'�:F"M.~T'^. .:_� +�+ +�•�si �\Je N' S�'!C'",4 Y ./ 4 Y .} ..�}.
-
See attached map showing the fields to be used for the utilization of waste water.
Application of Waste by Irrigation
Field Soil Type Crop Application Application
No. Rate (In/Hr) Amount (In.)
1
NoA
Bermuda
0.5
.5-1
2
Ra
Bermuda
0.4
.5-1
14
NoA
Row Crops
0.4
.5-1
THIS TABLE IS NOT NEEDED IF WASTE IS NOT BEING APPLIED BY IRRIGATION, HOWEVER A SIMILAR TABLE WILL
BE NEEDED FOR DRY LITTER OR SLURRY.
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 MONTHS. In no instance should the volume of
waste being stored in your structure exceed Elevation "see lagoon design_
Call the local Natural Resources Conservation Service (formerly Soil Conservation Service) or Soil
and Water Conservation District office after you receive the waste analysis report for assistance in
determining the amount per acre to apply and the proper application rate prior to applying the
waste.
Narrative of operation. -
Acres shown are wetted acres using a 3` traveller.
Overseeding of bermuda with small grain is optional
Row crop planting is optional.
Rage 4

- WASTE UTILIZATION PLAN ' `
�._._ _ . r
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of waste, he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner of the facility to
secure an update of the Waste Utilization Plan when there is a change in the operation,
increase in the number of animals, method of utilization, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climatic conditions, and level
of management, unless there are regulations that restrict the rate of application for other
nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but less than 10 tons per acre per
year providing grass filter strips are installed where runoff leaves the field. (See FOTG
Standard 393 - Filter Strip).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field-
6 When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland_ When applied to conservation tilled crops or grassland,
the waste may be broadcast provided the application does not occur during a season
prone to flooding_ (See "Weather and Climate in North Carolina" for guidance_)
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application_ No ponding should occur in order to control odor or flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen_
Page 5

(WASTE UTiM-ATlQN PL`ANt t Y
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered_
10 Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a
high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste
shall not be applied more than 30 days prior to planting of the crop or forages breaking
dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and from any perennial stream or river (other than an irrigation ditch or canal. Animal
waste other than swine waste from facilities sited on or after October 1, 1995), shall not be
applied closer than 25 feet to perennial waters_ (See Standard 393 - Filter Strips)_
12 Animal waste shall not be applied closer than 100 feet to wells_
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-ot-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site by a "technical specialist".
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that courses no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system_
Page 6

REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.)_ Areas shall be fenced as necessary to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping pumps, reels, etc_, should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption_ However, if animal waste is used on crops for direct human
consumption it should only be applied pre -plant with no further applications animal waste
during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soil shall be monitored and altemative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste analysis records shall be kept
for five years_ Poultry dry waste application records shall be maintained for three (3)
years_ Waste application records for all other waste shall be maintained for five (5) years.
23
Dead animals will be disposed of in a manner that meets North Carolina regulations.
Page 7

- !l�ASTE=UTIVIZATIM FLAN x
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: Johnson Farms#2
Owner / Manager Agreement
I (we) understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. I (we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new facilities will require a new
certification to be submitted to the Division of Environment Management (DEM) before the
new animals are stocked. I (we) also understand that there must be no discharge of
animal waste from this system to surface waters of the state from a storm event less
severe than the 25-year, 24-hour storm. The approved plan will be filed on -site at the farm
office and at the office of the local Soil and Water Conservation District and will be
available for review by DEM upon request.
Name of Facility Owner
(Please Print)
Eddie Johnson
Signature: Date
Name of Manager (if different from owner):
Signature:
Date:
..l -/If -63
Name of Technical Specialist: (Please print) Kraig A. Westerbeek
Affiliation: Murphy -Brown, LLC
Address (Agency):
Signature
P.O. Box 759

Sheetl
IRRIGATION SYSTEM DESIGN PARAMETERS
Landowner/Operator Name: Johnson Farms #2
Address: 905 White Pond Rd. West
Fairmont, NC 28340
Telephone: [phone]
Table 1 - Field Specifications
Approximate
Maximum
Useable Size
Field of Field
Number (acres)
Soil Type Slope % Crop(s)
County; Robeson
Date: 07/17/2003
Maximum
Maximum
Application
Application
per Irrigation
Rate
Cycle
(Inlhr)
(inches) Comments
Row Cropsr
_

Sheet2
TABLE 2 - Travelling Irrigation Gun Settings
Make, Model and Type of Equipment: 3" Hobbs Traveller
Travel Application TRAVEL LANE Wetted Nozzle Operating Operating
Speed Rate Effective Effective Diameter Diameter Pressure Pressure Arc
Hvdrant No. (ft/minl (in/hr.) Width(ft.) Lenoth(ft) (feet) (Inches) at Gun(osi) at reelfosi) Pattern Comments - Acres ner null

Sheet4
TABLE 4 - Irrigation System Specifications
Traveling
Solid Set
Irrigation Gun
Irrigation
Flow Rate of Sprinkler (gpm)
182
Operating Pressure at Pump (psi)
103.3
Design Precipitation Rate (inlhr)
0.31
Hose Length (feet)
7fl0
xxxxxxXX
Type of Speed Compensation
Mechanical
XXXXXXXX
Pump Type (PTO, Engine, Electric)
Engine
Pump Power Requirement (hp)
19.9
TABLE 5 - Thrust Block Specifications
THRUST BLOCK
LOCATION
AREA (sq. ft.)
90 degree bend
4.94
Dead End
3.5
Tee
2.45
Gate Valve
3.5
45 degree Mend
2.66
Page i

Sheets
IRRIGATION SYSTEM DESIGNER
Name: Kraig Westerbeek
Company: Murphy -Brown's
Address: PO Box 759 Rose dill, NC 28458
Phone: [phone]
Required Documentation
The following details of design and materials must accompany all irrigation designs:
1. A scale drawing of the proposed irrigation system which includes hydrant locations, pipelines, thrust block locations and buffej
2. Assumptions and computations for determining total dynamic head and horsepower requirements.
3. Computations used to determine all mainline and lateral pipe sizes.
4. Sources and/or calculations used for determining application rates,
5. Computations used to determine the size of thrust blocks and illustrations of all thrust block configurations required In the system
6. Manufacturer's specifications for the irrigation pump, traveler and sprinkler(s),
7. Manufacturer's specifications for the irrigation pipe and/or USDA-NRCS standard for IRRIGATION WATER CONVEYANCE.
8. The information required by this form are the minimum requireffients. It is the responsibility of the designer to consider all relevant (actors at a particular site and
address them as appropriate
9. Irrigation pipes should not be installed in lagoon or storage pond embankments without the approval of the designer.
NOTE: A buffer strip of 25' or wider must be maintained between the limits o1 the irrigation system and all
perennial streams and surface waters per NC Statutes.

Sheet6
Narrative of Irrigation System Operation
This system is designed to use a 3" hardhose traveller w/ 700' of hose for all pulls. Grower
should use a 1.08" ring nozzle at 60 pi pressure for all pulls. Pull 8 require that the arc angle
be manipulated as shown on the map. This must be done to adhere to buffer requirements for the farm.
Acres shown are 'wetted' acres as defined by Technical Guide Standards.
Equipment dealer will provide start up, winterization, and operation guidelines for equipment to be
use.

Sheet7
CALCULATIONS
RMWITIMMMM
Sprinkler Type: Nelson 150
Nozzle Size:
1.08 inches
Sprinkler Pressure:
60 psi
Flowrate(GPM):
182 gpm
Wetted Diameter:
300 feet
Lane Spacings
Desired Spacing (%): 70 %
Design Spacing(feet): 210 'PVC irrigation pipe normally comes in 20' pieces,
so round to the nearest multiple of 20.
Actual Spacing (feet): 200 feet
Actual Spacing (%): 67 %
Application Rate =(96.3xFlowrate)/(3.1415x(.9xradius)squared)
Design App_ Rate = 0.31 in/hr
300 degree arc = 0.37 in/hr
220 degree arc = 0.50 in/hr
180 degree arc = 0.61 in/hr
Travel speed = 1.605 x Flowrate / Desired application amount x Lane Spacing
Desired app. (in_) =
0.75 inches
300 degree arc =
1.95 ft/min
'220 degree arc =
2.34 ft/min
180 degree arc =
3.89 ft/min
IMMUMMM•
Velocity = .408 x Flowrate / pipe diameter squared feet/sec.**
**For buried pipelines, velocity should be below 5 feet per second
Pipe size
Velocity=
6 inches
2.06 ft/sec.
Page 1

Sheet?
Maximum Mainline Friction L95s
Most distant hydrant: 5
Total distance: 1100 feet
Friction Loss is figured using HazenMilliam's Equation
Friction Loss= 0.24 feet/100 feet
Max. Mainline Loss = 2.7 feet or 1.2 psi
Total Dynamic Head
Sprinkler Pressure:
60 psi
Loss through traveller:
35 psi
Elevation head:
0 psi
Mainline loss:
1.2 psi
Suction head and lift:
2.2 psi
5% fitting loss:
4.9 psi
TOTAL(TDH) =
103.3 psi or 238.6 feet
Horsepower Required
Horsepower = Flowrate x TDH(feet) / 3960 / Pump effeciency
Pump Description: Berkeley B3J
Pump Efficiency: 55 %
orsepower Required: 19.9 Hp
Thrust BlQeking
Thrust Block Area = Thrust / Soil Bearing Strength
Thrust:
4200 feet
Soil Bearing Strength:
1200 feet
End Cap:
3.5 ft2
90 degree elbow:
4.9 ft2
Tee:
2.5 ft2
45 degree elbow:
2.7 ft2
E!il2e Prert5ure Ratingk
Pressure Rating of Pipe to be Used: 200 psi
Max. Pressure on system when running: 103.3 psi
70% of Pressure Rating: 140 psi
If Max. Pressure on system is less than 70% of Pressure Rating, ©K
Page 2

Sheet7
NAI Positive Suction Head Check
NPSHA: 21
NPSHR: 7 *from pump curve
If NPSHA>NPSHR OK
Page 3

5heet8
ACREAGE CALCULATIONS
:
Pull # - - ---Wmdth
— LDnh Start,End #StopEnd-!Pull
Acres !Field # !Field-
-_
235;
265 !
0.72
0.58E-v
2.73
1 ;�
5.30 ` -
2
235.
235E
0.58�
2.57�
3
235!�
—340'
_0.72;
0.721
0.58;
3.13'
2-
4.�.. ------ ------235'
3681 �-0.72?
0.58;----'---
3.29;
5
235 t
%7
;
0.581
4.361
3
8.36
_0.72
0.58 i-
4-001-
7 -- - -
2351
4454—
0 72 --
- 0-58
3 70 i
4 =
6.78 —
8
235:
375;
0.48i
0.58
3-08
�26.86
!
j
F
€
3
r
!
3
Nage 1

PERFORMANCE - US. UNITS
MO. SEMES
SIG .GUN - 240 TRAJECTORY
= TAPER BORE NOZZLE.,
--
P 51
: GPlA r:tfJt4 {
- GAJyI -'
GPIs'.' CIA '.
- tiWIl .: oa7L'
79 '-
{iPY .-. D44 .
GPM'::, . k71A
OPE!'- . OW ,
:`GPM..:-, . MA '
:GPId - es: a
;.aa ., : WA
e
66 213'
Bi '--236
tp3 :=2
,-+W'
"a - �'.
1.Yt 25c'
152' 4
•�
�'z
NQ-
Ea
.�-''
vl.RAi.�
5'S - �8
f 3
t 64
f '
'
-
_,r�,w+�ii�z
��---
Y- SwRR4fir�
8t ?ae
se4 2.
-' J4 7ctT
•06 "VW
♦
'h1�:L-�+
'�0'
lra 2'S
'-'w3 M
�sLF_�{ryZw'Yti
1 �C atr
1.9 rElS
143 3i,
VS._ki"wY3Y=-sE1✓�.'
r26
1-146
k s�5 2f '
t&3 3k'
lr-� V&
tCF "
je' 325
�.KS:P�;
2P9'.
_ 7F.J' - S;a'
212 33S'
t5'� -
`e35 345'
.G
�' 313
-
2t19 - s 37l'
-erg} u
o��f� 1C��P.1V
t f-
;( -5 j,
L_Y:`' f:�i-`1�
.,�irz
��a V4°``;
��
�'�.'.'+%�'.
:XA s
4.5
"' � _...
��"
. is ;
;'��Z {' �
320
30)
3`35
:"5u
f-f5
Al
291) 't .,.
2�
Oct`
d`1u
`Itits .-
�qs '21A
aL?
}'r�"
�3
:rim
3 ._.-.
r.^
3G5
_-_�; .a
: 1 y
axe z �s
��.
u. �
370
3£fJ
415
-31G
`.�25
.'}Q4
7
--"..--
'-^+•�-�_,•--•-..3...L•.,ya�'r:
400
fr-5�.-

i
�j f

s' r
. f1v
Ap
t —ell
A ;?krl;
;o A
-Z MAk".12t
44
ol
Ot
V�k 0
141
.ky

WkU (Joins sheet 59)
w Was L
Pos
:c a Po$ yy eo NOB:
LYUP
r.
B
�a Ly ,
k waB
- lM1ra �vftNoA NaA
_.' GaA� u
B
GaA- .+
P°B m GaA W— waB
NoA
Was t_: \ Re
• {`!a8 ';r $9 � � � Ra RSA GoA .y�, i . _ � fMa
PoB iNAB '!' a
Po6 s B
a` l _ 4 . Wk
.aYw —a Cos ...-:- WkB GoA - - r
`s,;.
Wa
Poe
ILIA
NOA 1`'_
Wks m Pa8 "O
O
WaB yam' :* '-��' .r•=r_- �. x, +° o _ r•'�. -:t _ �S� t=ice
' NoA !• - �a 3~r-x µ� ; A a � ''� �e -„'� Ba •� IT..; � -f� ~ u
= o
• 't gg '` } - _�. �� -,� •r ':BSc �fr - rr
Wks
as
tv
Wa$.. it
'.,':.� +►� ^r'.� �' ..per �,�.],��"'_. 3'" - s;•• ]: `�
a ra
-� Five Fa7ic� P.B Co
- 'n.J,._- ,"^; -�•$. _Ma
Ly
T.
NOA•JNOA
Si �.••",. _ "`�zr..'� O
Was
lF
Nos
LY !iJr,;.ik - -_ _ r•-• Lyg„
Poe
} Poe _ t`• N 'x -?� _ •" ..':!
L. Project
as NOA Drawing: U5-A_�!'{5
r: Location: b Ce • -
,t. R `.5�5 K�
'..-a was Engineer. N °
Ra - --- °
Owner
Scale: " 1GG-7It .
Pre ared B vz4,r p .&erg•+ ®r r�

)n6011
Animal Waste Management System Operator Designation Form
wPCSOCC
NCAC 15A 8F .0201
1
Facility/Farm Name:
Permit #: 1'1/S %9 00_7 Facility ED#: 79 - 6_� County: RObe-50n
Operator In Charge (OIC)
Name: 16LYolI C� /I • ✓ynn an
First Middle Last Jr. Sr. efr_
Cert Type / Number: J_W R - I YL l �j Work Phone: 93 9
Signature: Date: i -
" I certify that i agree to my designation as the Operator in Charge for the facility noted_ I understand and will abide by the Hiles
and regulations pertaining to the responsibilities set forth in 13A NCAC 08F .0203 and Wing to do so can result in Disciplinary
Actions by the Water Pollution Control Systole Operators Certification Cotnrnission."
Back-up Operator In Charge (Back-up OIC) (Qpdonal)
11 01VI & 4 - j0_A0s t--' �/ �
First Middle Last Jr. Sr. erc_
Cent Type / Number_ l!Gib - ,g5,5-IF(v Work Phone: ( 9/0 ) 648 8-39G
Signature: _� Gyx Date- 05
-1 certify that I agree to rely designation as Ball; -rep Operator in Charge for thefacility noted_ I understand and will abide by the
rules and regulations pertaining to the responsibitities set forth in ISA NCAC 08F .0M and Failing to do so can result in
Disciplinary Actions by the Water Pollution Control System Operators Certification Commission.-
Owner/Permittee Name: _ gold 1 e- _ J d /4n.S u 0 v
Phone #: %/o I 6 a S - 93 Fax#: ( 1
Signature:- - - Q._�oywr Vale:
(Owner all au4tuxixed nl)
Mail or fax to: WPCSOCC
1618 Mail Service Center
Raleigh, N.C. 27699-1618
Fax:[phone]
(Retain a copy of this form for your records)
kcrned &2f)L17

October 8, 2007
Eddie Johnson
Eddie Johnson #2
905 White Pond Rd West
Fairmont, NC 28340
Michael F. Easley, Governor
William G. Ross Jr.. Secretary
North Carolina Dcpartment of Environment and Natural Resources
Coleen H. Sullins Director
Division of Water Quality
OCT 10 2007
Subject: Sludge Survey Testing Dates
Certificate of Coverage No. AWS780087
Eddie Johnson #2
Animal Waste Management System
Robeson County
Dear Eddie Johnson:
The Division of Water Quality (Division) received your sludge survey information on October 4,
2007. With the survey results, you requested an extension of the sludge survey requirement for
the lagoon at the Eddie Johnson #2 facility not to be required until 2009. Due to the amounts of
treatment volume available, the Division agrees that a sludge survey is not needed until 2009.
The results of the 2009 sludge survey are to be submitted by March 1, 2010.
Thank you for your attention to this matter. If you have any questions, please call me at (919)
715-6937.
Sincerely,
7#4A'C-�
Miressa D. Garoma
Soil Scientist
cc: Fayetteville Regional Office, Aquifer Protection Section
Central Files
O
NorthCarolina
'Alaturrt!!Y
Aquifer Protection scetion 1636 Mail Service Center
Intemet www.ncwaternualitv-org Location: 2728 Capital Boulevard
An Equal opportunity/Affirmative Action Employer- 50% Recycted1100% Post Consumer Paper
Raleigh, NC 27699-1636 Telephone: [phone]
Raleigh, NC 27604 Fax 1: [phone]
Fax 2: [phone]
Customer Service: [phone]

Eddie L. Johnson
405 White Pond Rd. West
Fairmont, NC 28340
aptnd:-,: 3. Lac-oan Sludge Survey Form
iarff, Fermi; or DWQ Id=ntiLoatiov lvtmioe- 4 AJ,5 Z&P _ .
Lmoor, ld=tifi=-Lion
C. Pessants) ta1•�hg Meats - t
_ . C ; €
D. Dat= of Measarsments fJ
Y. iv1;thods(De--,i= Used for Measuremeni of, , '� 4-
a. Distant'- fr the lagoon liquid surface to the top of th_ : ludge layer.
b. Discanct trrmi lvt lagoon liquid swf;act to the both, (.soil) of lagoon:
c. Thiclsmew of the sludge layer if mal:i o dint m=sxtrcrtent with "note sample:'"-:
T. Lagum, Sur=fz Ara (using dimensions at inside top ofbatth): _�-- _ . (acres)
!Draw sketzb of lagoon on a separm sbeet and list dimZamoas. and w- Culatt s acr. area.)
G. Esantate number of sampling poi :
RECEIVED
`t V 2
OENR-FAYETTEIALLE REGIONAL OFHCE
a. Lass roan 133 awe: Us-- E paints �l,
b. If mom than 133 acre, _ acres x 5 = - J � wico maximtsm of 34.
(Using akctcts and dim- our, davalop a msifom; `grid" tha7 bas nstnsbra of inttrrsettion pains£ that nsa�
most ; losrJy with the estimated number of swqimg potaU needed_ M=br-- tbn grid mu rhos pomu w
the hgwm grid to camespond witb t::e dam to br recorded far poims of mrasssre=M)
H. Conduct sludge sunk, and record data on "5h*z Sbrvey Data Sheef'.
L Ai sine of sludge snrvcy, also nrasurt ;tree dista= from the. Maxim= LigWd Level
to the Present Liquid. Izvel (measwe ai the lagoon gage pole):
Dam -mine dissance f = Mwximtmn Liquid Level to Afinimnm Liquid Lever:
(Determine from Plea or orthey L%gDm rtcords)
K- Calculate distance from prwmn Nquid surface Level to Minbm Liquid
isvei: Item J-- Item L as=miag present liuuid level is below Mzcr Liq. Level:
L. Record from sludge s Ycy data sheet the diawcc from the present liquid surface level
to the lagoon bdttorn (average for aU the meastu+cmentpoirtts):
M. Record from sludge survey data sheet the distance from the present bquid stuff-: lnytl
to "toe top of the sludge layer (average for ail the ant points):
lr'- Record from sludge survey daa shRt *.ht az age thickness of th:, sludge layer.
0. Calrailate the thicl-=s of the tx=ng Liquid Tr= t Zone (Item M - Item L'):
Notc: if item O is less than 4 fL, a s3tsdge r=wval and trtt7izzti w pia- may bt required by
N. C_ ,DWQ- S= your speriBc. permit or e.ontast DWQ for more fnformetiosc)
SLR
to, :
P. Proceed to Sludge Volume R+orl:sbcet if desire to calculate sludge volume .Lore rectaagu1ar shaped
legcon ,A itb uoifonn side slope.
Completed h,y:}�L�; '���' Date:
Print Name Sitmantxe

Eddie Johnson
Eddie Johnson #2
905 White Pond Road West
Fairmont NC 28340
Dear Eddie Johnson:
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
October 1, 2004
Alan W. Klimek, P. E., Director
Division of Water Quality
OCT 15 2004
DENR- FAYET EVILLE REGIONAL OFRCE
Subject: Certificate of Coverage No. AWS780087
Eddie Johnson #2
Swine Waste Collection, Treatment,
Storage and Application System
Robeson County
On June 1], 2004, the North Carolina Division of Water Quality (Division) issued a revised State General
Permit for swine facilities. The General Permit was issued in accordance with the directive of Senate Bill
733 (Session Law 2003-28).
In accordance with your application received on February 5, 2003 and in accordance with the directive of
Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to Eddie
Johnson, authorizing the operation of the subject animal waste collection, treatment, storage and land
application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AWS780087 which expires October 1, 2004,
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Eddie Johnson #2, located in Robeson County, with an animal capacity of no
greater than an annual average of 3552 Wean to Feeder swine and the application to land as specified in
the facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or
Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary,
they may be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a
rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009, Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Since this is a revised State
General Permit, it contains new requirements in addition to most of the conditions contained in the
previous State General Permit. Enclosed for your convenience is a package containing the new and
revised forms used for record keeping and reporting. Please pay careful attention to the record keeping
and monitoring conditions in this permit.
Aquifer Protection Section —Animal Feeding Operations Unit
1636 Mail Service Center, Raleigh, North Carolina 27699-1638
Phone: [phone] FAX: [phone] Internet: h2o.enr.state.nc.us
An Equal Opportunity/Affirmative Action Employer — 50% Recycled110% Post Consumer Paper
NorthCarolina
Nawnilly

If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current MRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 2H .0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100 foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Water Quality Staff may be reached at [phone], if you need additional information concerning
this COC or the General Permit, please contact Duane Leith at [phone].
Sincerely,
L/
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
Fayetteville Regional Office, Aquifer Protection Section
Robeson County Health Department
Robeson County Soil and Water Conservation District
Permit File AWS780087
APS Central Files

0
—/ — 6 /
Murphy -Brown LLc
February 18, 2003
Eddie Johnson
Johnson Farms
905 White Pond Rd. West
Fairmont, NC 28340
Mr. Johnson,
PO Drawer 856
2822 Hwy, 24 West
Warsaw, NC 28398
TeL [phone]
Fax:[phone]
r--
IN 2` tow !
i
Enclosed you will find an irrigation design for the use of a 3" traveIler, and a revised Nutrient
Utilization Plan for your #2 farm. Using a traveller actually increased the acreage available for application.
You will need to provide a copy of the NUP to the local SWCD, and DWQ's Non -discharge Permitting
Unit.
If you have any questions or concerns regarding this information, please feel free to contact me at
[phone].
ig
of Environmental Compliance

x?k -�.wr.:v .:-:�t�st�fi•:;,:a�r -�'..%a�aty n;,:yz;aa: �3"��?..._ues;,xPn�:<:.wxh;,;ao-xe:aWz+c:;,x¢�:.{:aae:.w --s::�ot>cK.. saw_ c't _ - �ecz+. .,--t".;-;.. �
I
s
hl �iy4A.T`.�'k21.`tit..,v�ti�. is � f�:"•ti-:{iZaq'��.,+�`�� � -.h:.�:' ~ � ` -
��;e'aooa:.�wecaes'�c`c>i".+bse�;y)3yp;inw,:a»'�%.���.'c<6rstiv7�j�.ar:•arm}aaasta^h`J;.:a.U.
PRODUCER:
LOCATION
TELEPHONE:
TYPE OPERATION:
Johnson Farms #2
905 White Pond Rd- West
Fairmont, NC 28340
[phone]
wean - feeder
NUMBER OF ANIMALS: 3552
(Design Capacity)
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface and/or groundwater. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied. This waste utilization plan uses nitrogen as the limiting nutrient. Waste
should be analyzed before each application cycle. Annual soil tests are strongly encouraged
so that all plant nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe
manner. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize. Soil types are
important as they have different infiltration rates, leaching potentials, cation exchange
capacities, and available water holding capacities. Normally waste shall not be applied to land
eroding at greater than 5 tons per acre per year. With special precautions, waste may be
applied to land eroding at up to 10 tons per year. Do not apply waste on saturated soils, when
it is raining, or when the surface is frozen. Either of these conditions may result in runoff to
surface waters which is not allowed under DEM regulations. Wind conditions should also be
considered to avoid drift and downwind odor problems. To maximize the value of nutrients for
crop production and to reduce the potential for pollution, the waste should be applied to a
growing crop or applied to bare ground not more than 30 days prior to planting. Injecting the
waste or disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content for
this type of facility. Acreage requirements should be based on the waste analysis report from
your waste management facility. Attached you will find information on proper sampling
techniques, preparation, and transfer of waste samples to the lab for analysis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A
NCAC 21-1.0217 adopted by the Environmental Management Commission.
Page 1

3,552 animals X 0.42 (tons) waste/animailyear
Amount of Plant Available Nitrogen (PAN) Produced Per Year
3,552 animals X 0.48 Ibs. PAN/animal/year
Guide Std. 633)
1,492 (tons) waste/year.
1,705 Ibs. PAN/year. (PAN from N.C.
Tech
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner
The following acreage will be needed for waste application based on the crop to be grown and
surface application:
Table 1: ACRES OWNED BY PRODUCER
Tract Field* Soil Crop Lbs. N Acres Lbs. N Month of
# No. Type Per Acre Utilized Application
T4069
1
NoA
Bermuda(H)
305
5.30
1616.5
March - Sept.
T4069
2
Ra
Bermuda(H)
225
6.42
1444.5
March - Sept.
Optional
T4069
1,2
NA
Small Grain
50
11.72
586
Sept. - April
Optional
T4069
3
NoA
Corn
137
8.36
1145.32
March -July
T4069
3
NoA
Wheat
120
8.36
1003.2
Sept. - April
T4069
3
NoA
Soybeans
110
8.36
919.6
June - Sept.
T4069
4
NoA
Corn
137
6.78
928.86
March -July
T4069
4
NoA
Wheat
120
6.78
813.6
Sept. - April
T4069
4
NoA
Soybeans
110
6.78
745.8
June - Sept.
Total 1 11.721 3,061.00
*This N is from animal waste only. If nutrients from other sources such as commercial fertilizer are
applied, they must be accounted for. N must be laased on realistic yield Mectation.
NOTE: The applicator is cautioned that P and K may be over applied while meeting the N
requirements. Beginning in 1996 the Coastal Zone Management Act will require farmers in some
eastern counties of North Caroline to have a nutrient management plan that addresses all nutrients.
This plan only addresses Nitrogen.
Page 2

Table 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowner must be attached)
(Required only if operator does not own adequate land [see
Required Specification 2])
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
# No. Type Per Acre* Utilized Application
" See footnote for Table 1.
Totals from above Tables
Acres Lbs. N
Utilized
Table 1
11.72
3,061
Table 2
0.00
-
Total
11.72
3,061
Amount of N Produced
1,705
Surplus or Deficit
(1,356)
NOTE: The Waste Utilization Plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to prevent over
application of nutrient or other elements_
Page 3

�+Ary •P I����� µ ..�� v4.` ��i�`:iv���v'-.�\'+Gv�. lS�..�ttiv?Q.
.«>.•���`,a•`,,w<�w-:; �h'�' w�-,�,.�.ai-s.., az.,,,ja,. max. ���as^�'.:
See attached map showing the fields to be used for the utilization of waste water.
Application of Waste by Irrigation
Field Soil Type Crop Application Application
No. Rate (In/Hr) Amount (In.)
1
NoA
Bermuda
0.5
.5-1
2
Ra
Bermuda
0.4
.5-1
3.4
NoA
Row Crops
0.4
.5-1
THIS TABLE IS NOT NEEDED IF WASTE IS NOT BEING APPLIED BY IRRIGATION, HOWEVER A SIMILAR TABLE WILL
BE NEEDED FOR DRY LITTER OR SLURRY.
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 MONTHS. In no instance should the volume of
waste being stored in your structure exceed Elevation *see lagoon desi n.
Call the local Natural Resources Conservation Service (formerly Soil Conservation Service) or Soil
and Water Conservation District office after you receive the waste analysis report for assistance in
determining the amount per acre to apply and the proper application rate prior to applying the
waste.
Narrative of operation:
Acres shown are wetted acres using a 3" traveller.
Overseeding of bermuda with small grain is optional M
Row crop planting is optional.
Page 4

�- p M s r - , •' sue^. ^!si-44rT.I --i r �.nx'r"cq— -
w T ° WASTE UTin iON LANrl-
3LL Y >t . ,.;
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of waste, he/she shall provide a copy of
an agreement with a landowner who is within a reasonable proximity, allowing him/her the
use of the land for waste application. It is the responsibility of the owner of the facility to
secure an update of the Waste Utilization Plan when there is a change in the operation,
increase in the number of animals, method of utilization, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based on soil type, available moisture, historical data, climatic conditions, and level
of management, unless there are regulations that restrict the rate of application for other
nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land that is eroding at 5 or more tons, but less than 10 tons per acre per
year providing grass filter strips are installed where runoff leaves the field. (See FOTG
Standard 393 - Filter Strip).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the irrigation field.
When animal waste is to be applied on acres subject to flooding, it will be soil incorporated
on conventionally tilled cropland. When applied to conservation tilled crops or grassland,
the waste may be broadcast provided the application does not occur during a season
prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor or flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
Page 5

REQUIRED SPECIFICATIONS
(continued)
Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a
high potential for leaching. Waste nutrient loading rates on these soils should be held to a
minimum and a suitable winter cover crop planted to take up released nutrients. Waste
shall not be applied more than 30 days prior to planting of the crop or forages breaking
dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and from any perennial stream or river (other than an irrigation ditch or canal. Animal
waste other than swine waste from facilities sited on or after October 1, 1995), shall not be
applied closer than 25 feet to perennial waters. (See Standard 393 - Filter Strips).
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted wetlands
provided they have been approved as a land application site by a "technical specialist".
Animal waste shall not be applied on grassed waterways that discharge directly into water
courses, and on other grassed waterways, waste shall be applied at agronomic rates in a
manner that courses no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
Page 6

m� ��.��� � _: VA,7TE�UTILIZATION�P AN• � - s.� �'�
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced as necessary to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption it should only be applied pre -plant with no further applications animal waste
during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
element. Zinc and copper levels in the soil shall be monitored and alternative crop sites
shall be used when these metal approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste analysis records shall be kept
for five years. Poultry dry waste application records shall be maintained for three (3)
years_ Waste application records for all other waste shall be maintained for five (5) years.
23
Dead animals will be disposed of in a manner that meets North Carolina regulations.
Page 7

WASTE UTILIZATION_ PAIN AGREEMENT
Name of Farm: Johnson Farms#2
Owner / Manager Agreement
I (we) understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. 1 (we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new facilities will require a new
certification to be submitted to the Division of Environment Management (DEM) before the
new animals are stocked. I (we) also understand that there must be no discharge of
animal waste from this system to surface waters of the state from a storm event less
severe than the 25-year, 24-hour storm. The approved plan will be filed on -site at the farm
office and at the office of the local Soil and Water Conservation District and will be
available for review by DEM upon request.
Name of Facility Owner:
{Please print)
Eddie Johnson
Signature: Date:
Name of Manager (If different from owner):
Signature: Date:
Name of Technical Specialist: (Please print) Kraig A. Westerbeek
Affiliation: Murphy -Brown, LLC
Address (Agency):
Signature
P_O_ Rny 759
J

Sheetl
IRRIGATION SYSTEM DESIGN PARAMETERS
Landowner/Operator Name: Johnson Farms #2
Address: 905 White Pond Rd. West
Fairmont, NC 28340
Telephone: [phone]
Table 1 - Field Specifications
Approximate
Maximum
Useable Size
Field of Field
Number (acres)
Soil Tvr)e Slooe % Croo(s)
County: Robeson
Date: 07/17/2003
Maximum
Maximum
Application
Application
per Irrigation
Rate
Cycle
(Inlhr)
(inches) Comments

Sheet2
TABLE 2 - Travelling Irrigation Gun Settings
Make, Model and Type of Equipment: 3" Hobbs Traveller
Travel Application TRAVEL LANE Wetted Nozzle Operating Operating
Speed Rate Effective Effective Diameter Diameter Pressure Pressure Are
Hvdrant No. (ftlmin) (inlhr.) Width(ft.) Lenath(ft) (feet) (Inches) at Gun(osi) at reel(osi) Pattern Comments - Acres oer null

Sheet4
TABLE 4 - Irrigation System Specifications
Traveling
Solid Set
Irrigation Gun
Irrigation
Flow Rate of Sprinkler (gpm)
182
Operating Pressure at Pump (psi)
103.3
Design Precipitation Rate (inthr)
0.31
Hose Length (feet)
700
xxxxx xx
Type of Speed Compensation
Mechanical
xxxxx CXX
Pump Type (PTO, Engine, Electric)
Engine
Pump Power Requirement (hp)
19.9
TABLE 5 - Thrust Block Specifications
THRUST BLOCK
LOCATION
AREA (sq. ft.)
90 degree bend
4.94
Dead End
3.5
Tee
2.45
Gate Valve
3.5
45 degree bend
2.66
Page 1

Sheets
IRRIGATION SYSTEM DESIGNER
Name:
Kraig Westerbeek
Company:
Murphy -Brown's
Address.
PO Box 759 Rose Hill, NC 28458
Phone:
[phone]
Required Documentation
The following details of design and materials must accompany all irrigation designs:
1. A scale drawing of the proposed irrigation system which includes hydrant locations, pipelines, thrust block locations and buffe
2. Assumptions and computations for determining total dynamic head and horsepower requirements.
3. Computations used to determine all mainline and lateral pipe sizes.
4. Sources and/or calculations used for determining application rates.
5. Computations used to determine the size of thrust blocks and illustrations of all thrust block configurations required In the system
6. Manufacturer's specifications for the irrigation pump, traveler and sprinkler(s).
7. Manufacturer's specifications for the irrigation pipe and/or USDA-NRCS standard for IRRIGATION WATER CONVEYANCE.
8. The information required by this form are the minimum requirements. It is the responsibility of the designer to consider all relevant factors at a particular site and
address them as appropriate.
9. Irrigation pipes should not be installed in lagoon or storage pond embankments without the approval of the designer.
NOTE: A buffer strip of 25' or wider must be maintained between the limits of the irrigation system and all
perennial streams and surface waters per NC Statutes.

Sheet6
Narrative of Irrigation System Operation
This system is designed to use a 3" hardhose traveller w/ 700' of hose for all pulls. Grower
should use a 1.08" ring nozzle at 60 pi pressure for all pulls. Pull 8 require that the arc angle
be manipulated as shown on the map. This must be done to adhere to buffer requirements for the farm.
Acres shown are 'wetted' acres as defined by Technical Guide Standards.
Equipment dealer will provide start up, winterization, and operation guidelines for equipment to be
use.

Sheet?
CALCULATIONS
Sprinkler Specifications
Sprinkler Type: Nelson 150
Nozzle Size:
1.08 inches
Sprinkler Pressure:
60 psi
Flowrate(GPM):
182 gpm
Wetted Diameter:
300 feet
Lane Spacings
Desired Spacing (%): 70 %
Design Spacing(feet): 210 'PVC irrigation pipe normally comes in 20' pieces,
so round to the nearest multiple of 20.
Actual Spacing (feet): 200 feet
Actual Spacing (%): 67 %
Application Rate =(96.3xFlowrate)/(3.1415x(.9xradius)squared)
Design App. Rate = 0.31 in/hr
300 degree arc = 0.37 in/hr
220 degree arc = 0.50 in/hr
180 degree arc = 0.61 in/hr
Traveller Steed
Travel speed = 1.605 x Flowrate 1 Desired application amount x Lane Spacing
Desired app. (in.) = 0.75 inches
300 degree arc = 1.95 ft/min
220 degree arc = 2.34 ft/min
180 degree arc = 3.89 ft/min
Mainline Velocity
Velocity = .408 x Flowrate / pipe diameter squared feettsec."
"For buried pipelines, velocity should be below 5 feet per second
Pipe size: 6 inches
Velocity= 2.06 ft/sec.
Page 1

Sh eet7
Maximum Mainline Friction Loss
Most distant hydrant: 5
Total distance: 1100 feet
Friction Loss is figured using HazenMilliam's Equation
Friction Loss= 0.24 feet/100 feet
Max. Mainline Loss = 2.7 feet or 1.2 psi
Total Dynamic Head
Sprinkler Pressure: 60 psi
Loss through traveller: 35 psi
Elevation head: 0 psi
Mainline loss: 1.2 psi
Suction head and lift: 2.2 psi
5% fitting loss: 4.9 psi
TOTAL(TDH) = 103.3 psi or 238.6 feet
Horsepower Required
Horsepower = Flowrate x TDH(feet)13960 / Pump effeciency
Pump Description: Berkeley B3J
Pump Efficiency: 55 %
orsepower Required: 19.9 Hp
Thrust Blocking
Thrust Block Area = Thrust / Soil Bearing Strength
Thrust: 4200 teet
Soil Bearing Strength: 1200 feet
End Cap: 3.5 ft2
90 degree elbow: 4.9 ft2
Tee: 2.5 ft2
45 degree elbow: 2.7 ft2
Pressure Rating of Pipe to be Used: 200 psi
Max. Pressure on system when running: 103.3 psi
70% of Pressure Rating: 140 psi
If Max. Pressure on system is less than 70% of Pressure Rating, OK
Page 2

NPSHA: 21
NPSHR: 7 *from pump curve
If NPSHA>NPSHR OK
Sheet?
Page 3

Sheet8
1 1 ACREAGE CALCULATIONS
I I
I
I
Pull _
I
I Wldth I Lenoth
i Start End
I StopEnd uL�
r�
FiUId# —
E gk ACM
1 2351
265
0.72
0.58
2.731
1
5.30
2 2351
235
0.72
0.58
2.57
3 1 2351
340
0.72
— 0.58
3.131
2
6.42
4 1 2351
368
0.72
0.58
3.29
5 1 2351
567
0.721
0.581
4.361
3
8.36
6 1 2351
500
0.721
0.58
4.001
7 1 2351 4451
8 I 2351 375;
0.721
0.481
0.581
0-581
3.701
3.081
4
6.78
j
_
1
I
I1
26.86
!
I
!
I I
I I
I
I
I
i
I !
I
I
!
Page 1

PERFORMANCE - U.S. UNITS
100 SERIES BIG GUN - 240 TRAJECTORY - TAP
150 R Ring Nozzles - Us Units
7 3 1 1-25 -Ring
f 1.34v Rini.1,41
Ri
7
M
DIA
;GPM
DtA
GPM
DIA !GPM
DIA
=GPM
01A
!GPM
----------
DtA
-
50,100
245
130
265
ASS
265
:205
304 ,25-5
320
1300
335
!350
00 110
260
"143
280
152
300
225
315i275
3., i5
1330
350
j385
7011.20.
270j155.
290. 197
310
t245
330 i285
35L1 i355
385
A15
.380
u�
3W
1210
32p
Zw
340 ;315
360
'380
38t3
445
395
90 135
290
175
310
223 330
7 5
350
390
;'475
405
100!
e; 143
-100
340
!290
360
14 5
2
400
'5W
415
31G
`195
330
'-247
350
:305
370 -370
300
_4 19-
f 525
425
120,157
375
j 2Q4
335
i25a
380
320
380 !3"
400
465
420
-.545
435

FEW
0
PERIMETER
Project JEM if- -To- lizi-S an t=A genj t(!! 7-
Dmm'ng:
LoCation:
rc -
Engineer U12f E- fta4 Al
scale: / "ell,
-.--
Pre ared 13y:
FPREPV,'RED Br-Carroll's Foods, Inc.

lot
Lf jv:
S,i
ct,
ul
IF
Ok
V!i
0, 1 '110 P...,
V�; LAN
.4.k
'37
J i
2. PA
1p
YWA
-31
Row.
XF,
I t
x1;
it

19
000oz:T Bioos
000 a 0 o D00 9
A DPW I
3 (991-92 sulor) I 1131000OW
B!M
_ N IO 'wk., Y • y� ,1:
r7"Ya p '` ~m Vo l�tir•.+ �� .k r-,.:•. �+ ! jj r �:'+ r ,r �? z ' tLS ?';
3;, rQ .t # �" m �(�ar�h`+�' �r i�fyr`,itl i �r" +i rjJ ��i �5�, •rri � 't.��}�',
♦M q �' �i'� Brni� �• j 'r' t�
.i. %L a..: is �' ��' �� � ik�:'+'"�}••j' s' ��,' .� � �' � I � '
43
%• m m' •y it +r` r'+{+''t�� +� '' ° .'+!�; a i
I � � �� O r 3 • s -. '+�y4:t: �R�[�}:1 ��:r7!'� '"k'ri .�, {+ �'Ma, � .. � � y�I i '
;. •. (7 m /�,ty',�r• r r�H�!'�Y' f"r(i!�y t ]� do J j� o + 1 8 Lu
} iN. } $ 1. •�' i' i` 2r, yt. _. it - i'J� Z r + iu r 7
m �) m .. +, �t?l},%f rs!rf i„ r, rr' ,f -„a.'i i• r- I
�,y. 0. ! d � � p �tiS X1� �' �•. ),i�'��1.�4`F �f �: ',{,�,.��-('�•� U r. �:.9 r 1. f� C N a7
Qu U L
Z m t ! n 'r i ii� �y 41_ "r' 3•., �0 '.•a Si�Sr 1,. r ' i'a Q} '3 :•:a C M :U
�` ��• •., t,v�" t �F� ;,' r i i�=�Zilit + :� { �',1 F n ' c O tt% c N
w t� a
.lyt'•'�y, ,.} � ,'�� '"'� l.�"h1;3 f ►' �_ � ^ > --I�yt r0 (D � 1
� � i� j , Rio � .s :�i#F��'lr ,3 � �� �r ij+ )• .
' • � f y � ;tit , r pP' K. �t �' � b 4 G-
' (v: 4� •i.. i' Ke �� {fr' }7' � 1�15 �*- *„ r m 1 .�. � z':� ..���.
.� 3 a G GYM - , :�•. d
a m
.m IX
Qod
f ~ ' 'r�•tIS•;L S lR 1 r o �e%'I" , z +'� . `1•!

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural. Resources
Alan W. Klimek, P. E., Director
Division of Water Quality
May 1, 2003
Eddie Johnson
Eddie Johnson #2
905 White Pond Road West
Fairmont NC 28340
Subject: Certificate of Coverage No. AWS780087
Eddie Johnson #2
Swine Waste Collection, Treatment,
Storage and Application System
Robeson County
Dear Eddie Johnson:
On April 28, 2003, the North Carolina General Assembly ratified Senate Bill 733 which directs the
Division of Water Quality (Division) to extend the expiration date of the Swine Waste Operation General
Permit AWG100000. Therefore, the General Permit has been re -issued by the Division to extend the
expiration date to October 1, 2004. During the period of this extension the Division will be working with
all interested parties on the development of a new version of the Non -Discharge General Permit.
In accordance with your application received on February 5, 2003 and in accordance with the directive of
Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to Eddie
Johnson, authorizing the operation of the subject animal waste collection, treatment, storage and land
application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AWS780087 which expired on April 30, 2003.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Eddie Johnson #2, located in Robeson County, with an animal capacity of no
greater than an annual average of 3552 Wean to Feeder swine and the application to land as specified in
the facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or
Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary,
they may be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a
rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until October 1, 2004. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
If your Waste Utilization PIan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Fa►
NWDME
Non -Discharge Permitting Unit Internet ht1pJ/h2o.enr.state.nc.us/ndpu
1617 Mail Service Center, Raleigh, NC 27699-1617 Telephone [phone] Fax [phone]
Customer Service Center Telephone 1-B77-623-6748
An Equal Opportunity Action Employer 50% recycled/10% post -consumer paper

Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per NRCS standards a 100 foot separation shall be maintained between water supply wells and any
lagoon or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located_ in a county covered by our Fayetteville Regional Office. The Regional .Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact J R Joshi at [phone] ext. 363.
Sincerely,
L/
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
Fayetteville Regional Office, Water Quality Section
Robeson County Health Department
Robeson County Soil and Water Conservation District
Permit File AWS780087
NDPU Files

Wettable Acres Determination Certification
Name of Facility: E,Qn 19: %n& OjV' Ocdiiem M ° Z Facility Number. TJP - V 7
Owner(s) Name: �DQt6 �i A!dj& AL_ _ _ Phone No: 06 Cz&-- 83F6
Mailing Address: _qp .T k&j-zaE Aegp _j&di klssr
JrRACACOAT& A1-C--*-S34-0
By signing this form, the facility owner and Technical Specialist acknowledge the completion of the
Wettable Acmes Determination. All necessary Wettable Acre Determination Field Data Sheets and
calculations were completed to conduct a Wettable Acre Determination. The facility's Waste
Utilization Plan has been amended as necessary to reflect actual wetted acreage. A copy of all
worksheets, calculations, and other Wettable Acres Determination documents, along with the
applicable Waste Utilization Plan and Wettable Acre Determination Certification will be filed with
the local Soil and Water Conservation District. A copy will also be kept on site with the Certified
Animal Waste Management Plan. Any future modifications must be approved by a technical
specialist and filed with the Soil and Water Conservation District prior to implementation. If any
modifications to the existing irrigation system or any new irrigation equipment was required to
adequately address the waste management needs of this facility, an Irrigation Specialist or
Professional Engineer has certified the design and installation below.
Owner
Owner
Technical Specialist Name: ^ 4? w to
Technical Specialist Signature: „� , _ Date: /
If assisted by an Irrigation Specialist or Professional Engineer please read and sign below:
Animal waste application equipment has been designed or modified to apply waste as necessary to
accommodate the waste management plan and according to NRCS Standards. Animal waste
application equipment has been installed according to NRCS Standards and is ready for use.
Irrigation Specialist/PE Name:
Irrigation Specialist/PE Signature: Date:
Submit this form to:
Attn: Sonya Avant
NC Division of Water Quality
Non -Discharge Compliance & Enforcement Unit
1617 Mail Service Center
Raleigh, NC 27699-1617
WADC - 7/"

WETTABLE ACRE PLAN
FARM# --- ------- EDDIE JOHNSON Not
TYPE FARM 3552 HEAD WEAN TO FEEDER
COUNTY -------- RO B E S O N
DATE ------------- 01 /26/01

! . CAUTION !
THE ATTACHED WASTE UTILIZATION PLAN IS TO BE FOLLOWED.
IF CHANGES ARE TO BE MADE IN CROPS, FIELDS, ACRES,
IRRIGATION, TRACTS, ETC., THIS WUP IS TO BE REVISED OR
AMENDED BEFORE ANY CHANGE IS MADE. ANY DEVIATION IN
THE PLAN AND WHAT IS HAPPENING IN THE FIELD MAY RESULT
IN NON-COMPLIANCE.

I
I

Wettable Acres Determination Certification
Name of Facility: FDn r jr Nr&q s o^I _ F,',rM & ° Z Facility Number: 78 - B 7
Owner(s) Name:, �D�i6 j'4'-& 1uu_ _ Phone No: 9/a 6z�.- 8396
Mailing Address: t74 o
-m AI•C-A—S a
By signing this form, the facility owner and Technical Specialist acknowledge the completion of the
Wettable Acres Determination. All necessary Wettable Acre Determination Field Data Sheets and
calculations were completed to conduct a Wettable Acre Determination. The facility's Waste
Utilization Plan has been amended as necessary to reflect actual wetted acreage. A copy of all
worksheets, calculations, and other Wettable Acres Determination documents, along with the
applicable Waste Utilization Plan and Wettable Acre Determination Certification will be filed with
the local Soil and Water Conservation District. A copy will also be kept on site with the Certified
Animal Waste Management Plan. Any future modifications must be approved by a technical
specialist and filed with the Soil and Water Conservation District prior to implementation. if any
modifications to the existing irrigation system or any new irrigation equipment was required to
adequately address the waste management needs of this facility, an Irrigation Specialist or
Professional Engineer has certified the design and installation below.
Owner Nam
Owner Sign
Technical Specialist Name:_._ 4w,gtn _.G A4dr4Af
Technical Specialist Signature: .14_„ Date: /
If assisted by an Irrigation Specialist or Professional Engineer please read and sign below:
Animal waste application equipment has been designed or modified to apply waste as necessary to
accommodate the waste management plan and according to NRCS Standards. Animal waste
application equipment has been installed according to NRCS Standards and is ready for use.
Irrigation Specialist/PE Name:
Irrigation Specialist/PE Signature:_ _ _ Date:
Submit this form to:
Attn: Sonya Avant
NC Division of Water Quality
Non -Discharge Compliance & Enforcement Unit
1617 Mail Service Center
Raleigh, NC 27699-1617
WADC - 7/99

,. CERTIFIED ANINUL WASTE MANAGEMENT PLAN
WETTABLE ACRES WORKSHEET
Farm Name: E E , EafM � z Faulty Number _78 - A7
Manager or Producer
ew
Phone
(9, i 6gf-8346
Technical Specialist:
iv�-00 1> so At
Phone rr 9.b
-- ¢-
Facility Contact:
�!?l�/E
�/oeyNSa �r
_ Phone r Pip 1 Sze — s394
Mailing Address: _
9,0 .s
l4/yZr' =- '4"D )?O f0
k/i;3 —
�s6tir 1 Al- C -
Was farm sited for animals prior to 10/1195: Yes N
If No, date farm sited for animals:
Irritation Svstem TvQe LF.x! Srj�jG 5g5r'U M�
(Check all that apply)
Stationary sprinkler with permanent pipe
Stationary sprinkler with portable pipe
Stationary gun with permanent pipe
Stationary gun with portable pipe
6 18 19V
Center -pivot system
Linear -move system
Hose drag traveler
Acres calculated should correspond to that shown in the Waste Utilization Plan and
Form IR.R-2.
To the best of my knowledge, this worksheets) and map(s) provides an accurate
representation of the system used to irrigate the animal waste generated by this operation_
am; ] l a Q I -eq/
Signaft�ianaaer or Producer) Date
C00102070319

eAWMp Wenahk 1crc SLat;.,a Firld Dag Sho, 2r20/99
STATIONARY GUN SYSTEM
FIELD DATA SHEET
1. Gun make and model number dl&v v lea -f Nz4s•a i$o
AhED�5 V ^r /Y6LjOK r .
2. Gun nozzle sue /aa = v" [inch],o = i ►8 ring orifice, taper bore orifice
3. Lateral spacing /62 ' [feet] by Gun spacing along lateral Ago ' [feet]
4. Operating pressure at the gun So [,Dsi]
S. Gun wetted diameter o o feet]. measured or ✓ determined from gun chart
6. Number of guns operating at one time " 2
7. Total number of guns or gun locations in the system 2 3 Gu ttLoc.ssr7 au s
Exterior Guns: ✓ part circle ✓ full circle
Interior Guns: full circle
Gun Locations Permanently Marked: des no
8. Supply Line Permanent Pipe Portable Pipe
** 9. Lateral line size _ [inch]. If more than one size, indicate size and approximate
length of each. Can be done on the map.
** 10. Lateral line length [feet]. (Longest lateral)
**11. Supply line size ('` Finch]. If more than one size, indicate size and
approximate length of each. Can be done on map.
**12. Supply line length [feet]. Maximum pumping distance_
**13. Pump make and model number z e"y g Prm 6 11 6 1/10117�
** 14. Pump capacity i zoe, [gpm]
** 15. Engine make and model number /.So HP Tieftc7 a+� T , or
** 16. Electric motor horsepower and rpm [hp] ,[rpm]
Note: It is strongly recommended that gun wetted diameter be field
measured. It should be done on the longest lateral about half -way down the
lateral. -
* Locate each gun or gun location on the map. Indicate whether full -circle or part -circle
Show the location of the supply line. Irrigated acres will be determined by lateral line, by
zone or by field..
* * Optional data, furnish where possible
C00102070341
*** Information furnished by
t ,I
and/or
Sim of OAim or Facility Representative Signaturz of T-.hnic w Spwiaust
�c7DIE/!►vSoK
Printed Name of Owner or Facility Repre-sentative
_ 9 umao 485-4 K -
Printed Nam of Technical Specialist
Date
Date _! �I G%!
*** Only the person or persons collecting the data Rhnnld cetn, tha riata cl,pto-t

'0
Lit k
of
CL
I V1
lei
Jr 41
ri
ZVI
IV
7R, 441 :.�14WN
Olt-
Av

r Po8 Ly Nos_ -
i _
Noel
Go4
Ly F t Ra Lys �l
vas
wa8 `r - ' iNoA f n
NoA r m
Yoh NoA ois
GoA
PoB GoA
.� was Was
WaB p
NoA
•*�a r.' - _„� s: ry-,- waB t Re s NOB L Wa._
Nos `i.�.?.>1 '3' • Ra w♦� �� �1ysB•' -
Was.
x Pos a
• 5�`r�N:l.- `•C'* .T4. +1r[ ? WasVftB
�1 e
y
LAZ
WaB 1:�i: �F� •wWkB _ GoA
WaH t Be '
Poe
ill
Wk6 �...4-;i, i_-i , + _ Wks m�'xj PnH f+o O
wa 6 h = '3 r • r
s T �.� � � T r.- - 't Pn - -t•�'� '� .�
- 7
Cn
fir_=- - .+:.t•' e- � �-' ' r - ..y fvsy, a .: • _ � � -
g_ Mfa9! 0 Poe 't• 'iF '� ,isr t +, yr y y` r i WkB
tj
r—• J � , A �.'.`I •... _� i h �. ems. .. + B.P.
Was
44
sIMIbH S . t yF. -r: •t x i .' ..;vCx�•- _ T ' -�" _ O
ZY
yFi+f Fosksl-- POB • MA2. N
NoB�waBi m� • Ly - (-- Y},-- y�?•�. tea- �� ,
NOA NOA. rt -* �x tii•` D
aA
_ * A IF
PO H tip- *^arc"� PaB NOAi-
mb ": project:
[ NOA r Drawing: USA - tii&5�' L5 MAqR°
Page -.
Location: Ro��oK C� -- ---- --
;dY. wad Engineer
Re
. - — ---- -- '� Nn =
Owner: E7DD 1_E-rommS&N.- — --. FEE
Scale:
Pre paced B : ylrRo ld�ej-ory ai t�

s
;..I to, ..
L
QQ
-

ETE—
FLD 1
v
Project: IEpVIF_ UbKwSom 'FAeM -N!!Z_ -
Drawing: lemBEK.F—
Location: px, P BSc x f,,
Engineer.
Owner n !21
Scale:
PREPARED BY:Carroll's Foods, Inc.
DATE:01/26/01 TIME:12:14:16 PM PAGEA'

LXIUVIT D-1
IRRIGATION SYSTEM DESIGN PARAMETERS
Landowner/Operator Name; ti/a,yF/Sony .F�9 nr .2.Z— County; kaA�Sa�y_
Address; 9495 ulw"Lg
Dale; 0/4kL©l
Telephone: 6 �. 6 -- '9 396
TABLE I - Field Specifrcolions
Fleldl
Nun+ber
Approslwale
M411111une
ugrob Ile I
orFteldl
acres
3>M(P4(4 a
Boll Type
Slope
%
Crop(j)(
Maximum
Applleallon
hale
lidbr
Ataslnum
Applieallon
per Irrirallon
Cycle3
IIreITO)
Coiurnrrds
o 14
W&JIS6
se
!, oe>
5.7 z-
RA-t
/, c c
3
.Z
0r R Ld ZHbVR• ufNrCogµ
4-
No A
,sa
ISee attached snap.
2'1'otnl field acreage minus rchuircd buf%r areas. '
31tefer to N. C. Irrigation Guide, Field Office Teclmlcal Guide, Section II G. Annual application must not exceed the agronomic rules for Ilse soil und.croh used.
C00i02474433
NRCS, NC
1UNR, 1996
a

TABLE 3 - Solid Set Irrigation Gun Settings
e--M IF_ TO-f4N,50N #k 7-
Make, Model and Type of Egtdpnlertf:
-- -_ -- NELSor<c 100 w I.a NazZEL 150 W1 1•ll3 1011416
Field Not
and
Line Not
Number or
Hydianls
Welled
Diameler
(feel)
Hydrant Spacing (h)
Along Between
Pipeline Pipelines
Au 6/6( 1
Application
110ek-
InAu
OPERATWO PARAMETERS
Noiule operaling Operaling
Diarneler Pressure Time
inches] @ Oun (psi) Q H deanl hr)
Comments
/
4
3-221CP C7
/ 8a '
80 ,
o
.50
Oe C!ru VP G —T--
0 0'
o'
/ a
.Ara
© R M
a
'See allached map provided by the Field Office for field localion(s).
1Show separate entries for each pipeline Will hydrants In each field.
204,9po, x 60 /v,,^IH It
j Pc I K= Z"7r l S Z Ll &(-
Irrigation Parameters
Ocluber 1995
12 , Z 4-0
¢S i��hr
Ilona 11n-.

CAWMP WETTABLE ACRE COMPUTATIONAL WORKSHEET
1. Farm Number EDZDIr. Fwxscrr A/9Z Fe. � -78-87
2. Irrigation System Designation Existing
3. Irrigation System Hard -Hose 5Z�7_A_nouAfZy Gv,
4. # Exterior 23
5. Wetted Diameter Sao
6. Spacing 1 So,
# Interior
,p r, (As % of wetted diameter)
LD
INT.
E
AC.
SPRINKLERS
TOTAL AC.
TABLE
COL.
�
✓
a.953
¢
�.8
3
C
Z
►�
o. 95 3
57 7Z
-3
C
3
✓
�. �' 53
7
,G G 7
3
C.
4-
✓
o. 4 s
5 .7z
3
c
;.1.9;-
TOTAL WETTABLE ACRES
Wettable Acre Computational Worksheet Completed by:-�
Date : / �/

COMPUTATION SHEET FOR D G THE NUMBER OF
PUMPING HOURS PER FIELD MIL
) NOT TO EXCEED THE
ALLOWABLE APPLICATION RATE/HOUR
GIVEN: 1 ACRE INCH = 27,152 GALLONS
1. FARM NAME: EEzp ff-= T p - -* Z'
2. TYPE GUN: o
3. PRESSURE AT GUN: ( 5a PSI)
4. NOZZEL SIZE: ( Aa IN.)
5. PUMPING RATE FROM MANUFACTORS CHART: { 7_0¢ GPM)
6. FIELD (PULL) : ( z NO. )S3 4-
7. FIELD (PULL) SIZE: { e-253 AC.
8. ALLOWABLE APPLICATION RATE 0.4LO (IN. PER HOUR FROM WASTE
UTILIZATION PLAN OR IRRIGATION PLAN, BASED UPON SOIL TYPE)
STEP # 1 (GALLONS/HR
MULTIPLY PUMPING RATE 2--"4- GPM x 60 MINUTES = 12- L¢a GAL/HR
STEP # 2 (GALLONS/FLD)
MULTIPLY FIELD SIZE 09957 (AC.) X 27,152 GAL. = 2-S87G GAL/FLD
STEP # 3 (TOTAL GALLONS TO BE PUMPED)
MULTIPLY GAL/FLD X .__APPLICATION RATE
(TOTAL GALLONS TO BE PUMPED)
STEP # 4 (TOTAL TIME/FLD)
DIVIDE TOTAL !0,.3?0 _ GALLONS BY PUMPING RATE GAL/HOUR
EQUALS (=) 85 HOURS (MAXIMUM NUMBER OF PUMPING HOURS PER
APPLICATION FOR THE ABOVE FIELD)
STEP # 5 TOTAL TIME AC
DIVIDE oaf3s HOURS BY a_ 9S3 ACRES IN FIELD
=a. 65 HR 0. "MIN (0. MIN X 60 MIN) =0 HOUR(S) AND, - MIN
PUMPING TIME PER APPLICATION PER ACRE
ADDITIONAL FIELDS WITH SAME SYSTEM:
MW:"ulirl�
1. FARM NAME: JOHN DOE
2. TYPE GUN: HOBBS
3. PRESSURE AT GUN (PSI):
4. NOZZEL SIZE (INCHES):
5. PUMPING RATE (GPM):
6. FIELD (PULL) NUMBER:
7. FIELD (PULL) SIZE:
S. ALLOWABLE APPLICATION
50
1.0
205
3A
5.4 ACRES
RATE (IN/HR): 0.50
STEP
,#1
205 GPM X 60
MINUTES
= 12,300
GAL HR
STEP
12
5.4 ACRES X
27,152 GAL
= 146,621
GAL/FIELD
STEP
,#3
146,621 GAL
X 0.50 IN
- 73,310
GAL
STEP
#4
73,310 GAL /
12,300 GPH
= 5.96
HOURS
STEP
#5
5.96 HOURS /
5.4 ACRES
- 1 HOUR 6 MINUTES

COMPUTATION SHEET FOR DETERMINING THE NUMBER OF _PUMPING_ HOURS PER_
FIELD PULL NOT TO EXCEED THE ALLOWABLE APPICATION RATE HOUR
GIVEN: 1 ACRE INCH = 27,152 GALLONS
1. FARM NAME ,I-
2. TYPE GUN /YE45pN roo
3. PRESSURE AT GUN (PSI) S�
4. NOZZEL SIZE (INCHES)
S. PUMPING RATE FROM MANUFACTORS CHART (GPM 7w ¢ X 9 0 % FOR WETTED
DIA = GPM)
6. FIELD (PULL) NUMBER
7. FIELD (PULL) SIZE (AC) .453
8. ALLOWABLE APPLICATION RATE _.50 (INCHES PER HOUR FROM WASTE
UTILIZATION PLAN OR IRRIGATION PLAN - BASED UPON SOIL TYPE)
STEP #-1 (GALLONSIHRI
MULTIPLY PUMPING RATE ZQ4-- GPM X 60 MINUTES = _ 32,L4-9 _ GAL/HR
STEP # , 2 -(GALLONS/LD)
MULTIPLY FIELD SIZE 4.953 (AC.) X 27,152 GAL. _ 25876 GAL/FLD
STEP #,3 (TOTAL -GALLONS TO BE PUMPED)
MULTIPLY GAL/ FLD 96", R76 X APPLICATION RA_ TE QSa INCHES = 1 Z. 438
(TOTAL GALLONS TO BE PUMPED)
STEP #_4 (TOTAL TIME/FLD)
DIVIDE TOTAL 7z}.438 GALLONS BY PUMPING RATE 2z-.z4-c> GAL/HOUR
EQUALS (=) / a-5 HOURS (MAXIMUM NUMBER OF PUMPING HOURS PER
APPLICATION FOR THE ABOVE FIELD)
STEP #_ 5 (TOTAL TIME/AQ
DIVIDE /• 05 HOURS BY _ D •S 3_ ACRES IN FIELD
IF . o (0. /0 MIN X 60 MIN) = r HOUR S ) AND 6 MIN
PUMPING TIME PER APPLICATION PER ACRE
ADDITIONAL FIELDS WITH SAME SYSTEM:
EXAMPLE
1. FARM NAME: JOHN DOE
2. TYPE GUN: HOBBS
3. PRESSURE AT GUN (PSI)
4. NOZZEL SIZE (INCHES):
5. PUMPING RATE (GPM):
6. FIELD (PULL) NUMBER:
7. FIELD (PULL) SIZE:
S. ALLOWABLE APPLICATION
50
1.0
205 X 90% = 185 GPM
3A
5.4 ACRES
RATE (IN/HR): 0.50
STEP
#1
185 GPM X 60
MINUTES -
11,100
GAL HR
STEP
#2
5.4 ACRES X
27,152 GAL =
146,621
GAL/FIELD
STEP
13
146,621 GAL
X 0.50 IN -
73.310
GAL
STEP
14
73,310 GAL /
11,100 GPH =
6.60
HOURS
STEP
15
6.60 HOURS /
5.4 ACRES =
1 HOUR 13 MINUTES

Page 1 CORN/WHEAT ROTATION
WASTE UTILIZATION PLAN
------------------------
Producer-----:EDDIE JOHNSON County: ROBESON
Name of Farm -:FARM Not
Location-----:905 WHITE POND RD WEST
FAIRMONT, NC 28340
Phone -------- :910 628-8396
Type Operation-------------: WEAN -FEED
Number of Animal------------: 3552
Storage structure----------: Anaerobic Lagoon
Method of application------: Irrigation
Amount of waste produced per year---------------: 1500 tons/year
Amount of plant available N (PAN) produced/year-: 1705 lbs./year
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the
crops in the fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting
nutrient. Waste should be analyzed before each application cycle.
Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be
grown.
Several factors are important in implementing your waste
utilization plan in order to maximize the fertilizer value of the
waste and to ensure that it is applied in an environmentally safe
manner:
1. Always apply waste based on the needs of the crop to be grown
and the nutrient content of the waste. Do not apply more
nitrogen than the crop can utilize.
2. soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall not be applied to land eroding at more
than 5 tons per acre per year. Waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on saturated soils, when it is raining, or
when the surface is frozen. Either of these conditions may
in runoff to the surface waters which is not allowed under DWQ
regulations.
5. Wind conditions should also be considered to avoild drift and
downwind odor problems.
6. To maximize the value of the nutrients for crop production and
to reduce the potential for pollution, the waste should be
applied to a growing crop or applied not more than 30 days
prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.

Page 2
This plan is based on the waste application method shown above. If
you choose to change methods in the future, you need to revise
this plan. Nutrient levels for different application methods are
not the same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from
your waste management facility. In some cases you may want to have
plant analysis made, which could allow additional waste to be
applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content
and the crop type. Lime must be applied to maintain pH in the
optimum range for specific crop production.
This waste utilization plan, if carried out, meets the
requirements for compliance with 15A NCAC 2H .0217 adopted by the
Environmental Management Commission.

Page 3
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract
Field
Soil
Crop
Yield
No.
No.
Type
Code
/Acre
4069
1
NORFOLK
L.
N/A
4069
1
NORFOLK
C
6.1
4069
2
RAINS
L
N/A
4069
2
RAINS
C
4.5
4069
3
NORFOLK
W
60
4069
3
NORFOLK
D
110
4069
4
NORFOLK
W
60
4069
4
NORFOLK
D
110
Lbs. N
Unit
Acres
7=_
50.00 5°
50. 00 3K
50. 00 0
50.00 11�K
240 14
1..25 1l
2.40 �yw
1.2531
Lbs. N Month to
Used Apply
190.5 S-APRIL
3.8 1162. MAR-OCT
286 S-APRIL
5.7 1287 MAR-OCT
479.5 S-APRIL
6.7 917.1 MAR-JUL
411.8 S-APRIL
5.7 786.5 MAR-JUL
Total 21.9 5521
Available Nitrogen (includes commercial) 1705
Surplus Or Deficit -3816
Crop codes: Crop -unit
A=Barley-bu.
B=Bermudagrass(graze)-tons
C=Bermudagrass(hay)-tons
D=Corn(grain)-bu.
E=Corn(silage)-tons
F=Cotton-lbs. lint
G=Fescue(graze)-tons
H=Fescue(hay)-tons
I=Oats-bu.
J=Rye-bu.
K=Small grain(graze)-acre
L=Smali grain(hay)-acre
M=Sorghum(grain)-cwt.
W=Wheat-bu.
Y=Fescue(pasture)-tons
Z=Bermudagrass(pasture)-tans
O=Soybeans-bu.
R=Matua(graze)-tans
U=Millet(graze)-tans
Applying the above amount of waste is a big job. You should plan
time and have appropriate equipment to apply the waste in a timely
manner.
The applicator is cautioned that P and K may be over applied while
meeting the N requirements. In the future, regulations may require
farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only
addresses nitrogen.
In interplanted fields (i.e. small grain, etc, interseeded in
bermudagrass), forage must be removed through grazing, hay and/or
silage. Where grazing, plants should be grazed when they reach a
height of six to nine inches. Cattle should be removed when plants
are grazed to a height of four inches. In fields where small drain
etc, is to be removed for hay or silage, care should be exercised
not to to let small grain to reach maturity, especially late in
the season (i.e. April or May). Shading may result if small grain
gets too high and this will definitely interfere with stand of
bermudagrass. This loss of stand will result in reduced yields and
less nitrogen being utilized. Rather than cutting small grain for
hay or silage just before heading as is the normal situation, you
are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the
season, depending on time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September

Page 4
or early October. Drilling is recommended over broadcasting.
Bermudagrass should be grazed or mowed to a height of about two
inches before drilling for best results.
Caution must be exercised in grazing or haying summer annuals
under stressed conditions. Nitrate poisoning may occur in livestock
Sampling forage or hay for nitrate levels is recommended.
Acres shown in the tables are considered to be the usable acres
excluding required buffers , filter strips along ditches, odd
areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the field listed may, and most likely will be, more than
the acres shown in the tables.
see attached map showing the fields to be used for the utilization
of animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provision for periodic
land application of sludge at agronomic rates. The sludge will be
nutrient rich and will require precautionary measures to prevent
over application of nutrients or other elements. Your production
facility will produce approximately 256 lbs. of plant available
nitrogen per year in the sludge.
If you remove sludge every 5 years, you will have approximately
1279 lbs. of PAN to utilize. assuming you apply this PAN to
hybrid bermudagrass hayland at the rate of 300 lbs. of nitrogen
per acre, you will need 4 acres of land. If you apply the
sludge to corn at the rate of 125 lbs. of nitrogen per acre, you
will need 10 acres of land. Please be aware that these are
only estimates of the PAN and land needed. Actual requirements
could vary by 25% depending on your sludge waste analysis, soil
types, realistic yields, and application methods.

Page 5
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate
of the soil at the time of irrigation such that runoff or ponding
occurs. This rate is limited by initial soil moisture content,
soil structure, soil texture, water droplet size, and organic
solids. The application amount should not exceed the available
water holding capacity of the soil at the time of irrigation nor
should the plant available nitrogen applied exceed the nitrogen
needs of the crop.
If surface irrigation is the method of land application for this
plan, it is the responsibility of the producer and irrigation
designer to ensure that an irrigation system is installed to
properly irrigate the acres shown in tables. Failure to apply the
recommended rates and amounts of nitrogen shown in the table may
make this plan invalid.
The following table is provided as a guide for establishing
application rates and amounts.
Applic
Applic
Tract
Field
Soil
Rate
Amount
No.
No.
Type
Crop
(in/hr)
(inches)
4069
1
NORFOLK
CB HAY/SG
0.5
1.00
4069
2
RAINS
CB HA SG
0.4
1.00
4069
3
NORFOLK
EAT CORN
1.00
4069
4
N 0:7FOLK
WHEAT/COR
0.4
1.00
This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations the application amount shown cannot be
applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180 days of temporary storage and
the temporary storage must be removed on the average of once every
6 months. In no instances should the volume of the waste be stored
in your structure be within the 25 year 24 hour storm storage or

Page 6
one foot of freeboard except in the event of the 25 year 24 hour
storm.
It is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply
the correct rates to the acres shown in the tables. Failure to
apply the recommended rates and amounts of nitrogen shown in the
tables may make this plan invalid.
Call your technical specialist after you receive the waste
analysis report for assistance in determining the amount of waste
per acre and the proper application rate prior to applying the
waste.
NARRATIVE OF OPERATION
THIS WUP HAS BEEN AMENDED TO SHOW WETTABLE ACRES. FIELDS 3,4 ARE
IN A 2 YEAR ROTATION OF WHEAT, SOYBEANS, CORN. THIS PLAN IS FOR THE
CORN YEAR. ONE HALF OF THE WHEATACRES WERE USED FOR EACH YEAR OF
OF THE ROTATION. THESE ACRE DO NOT SHOW UP OF THE PLAN DUE TO
THE NATURE OF THE COMPUTER PROGRAM.

Page 7
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: FARM Not
Owner/Manager Agreement
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of
the waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
North Carolina Division of Water Quality (NCDWQ) before the new
animals are stocked. I (we) also understand that there must be no
discharge of animal waste from this system to the surface waters
of the state from a storm event less severe than the 25-year, 24-
hour storm. The approved plan will be filed on -site at the farm
office and at the office of the local Soil and Water Conservation
District and will be available for review by NCDWQ upon request.
Name of Facility Owner: EDDIE JOHNSON
(Please print)
r
signature: Date:
Name of Manager(If different from owner):
Signature:
Name of Person Preparing Plan: Howard Hobson
(Please print:)
Date:
Affiliation: Carroll's Foods, Inc. Phone: [phone]
Address: P O Drawer 856
Warsaw, NC 28398
Signature: Date: 11 ?W V 1

Page 8
WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
EXHIBIT A-6
NRCS, NC
DUNE, 1996
1. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or direct
discharge during operation of land application. Any discharge
of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the producer
either owns or has a notarized agreement for use of adequate land
on which to properly apply the waste. If the producer does not own
adequate land to properly dispose of waste, he/she shall provide a
copy of a notarized agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen
needs for realistic crop yields based on soil type, available
moisture, historical data, climate conditions, and level of
management, unless there are regulations that restrict the rate
of application for other nutrients. Actual yields may be used in
lieu of realistic yield tables at the discretation of the planner.
4. Animal waste shall be applied on land eroding less than 5 tons per
acre per year. Waste may be applied to land that is eroding at more
than 5 tons but less than 10 tons per acre per year providing grass
filter strips are installed where runoff leaves the field.
(See FOTG Standard 393-Filter Strips)
5. Odors can be reduced by injecting the waste by disking after waste
application. Waste should not be applied when there is danger of
drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding,
it will be soil incorporated on conventionally tilled cropland.
When applied to conservation tilled crops or grassland, the waste
may be broadcast provided the application does not occur during
a season prone to flooding. (See "Weather and Climate in North
Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor and flies.
8. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste should be applied on actively growing crops in such
a manner that the crop is not covered with waste to depth that
would prohibit growth. The potential for salt damage from animal
waste should also be considered.
10. Waste nutrients shall not be applied in fall or winter for spring
planted crops on soils with a high potential for leaching. Waste
nutrient loading rates on these soils should be held to a minimum
and a suitable winter cover crop planted to take up released
nutrients. Waste shall not be applied more than 30 days prior
to planting of a crop or forages breaking dormancy.

Page 9
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component
of a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after 10/1/95, shall
not be applied closer than 25 feet to surface water. This
distance may be reduced for waters that are not perennial pro-
vided adequate vegetative filter strips are present (See
Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet from wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animals waste shall not be discharged into surface waters,
drainageways or wetlands by a discharge or by over spraying.
Animal waste may be applied to prior converted cropland provided
it has been approved as a land applications site by a "technical
specialist". Animal waste applied on grassed waterways shall
be at agronomic rates and in a manner that causes no runoff or
drift from the site.
15. Domestic and industrial waste from washdown facilities, showers,
toilets, sinks, etc., shall not be discharged into the animal
waste management system.
17. A protective cover of appropriate vegetation will be established
on all disturbed areas (lagoon embankments, berms, pipe runs,
etc.). Areas shall be fenced, as necessary, to protect the
vegetation. Vegetation such as trees, shrubs, and other woody
species, etc. are limited to areas where considered appropriate.
Lagoon areas should be kept mowed and accessible. Lagoon berms
and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18. If animal production at the facility is terminated, the owner
is responsible for obtaining and implementing a "closure plan"
which will eliminate the possibility of an illegal discharge,
pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept
on site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption
it should only be applied preplant with no further applications
of animal waste during the crop season.
21. Highly visible permanent markers shall be installed to mark the
top and bottom elevations of the temporary storage (pumping
volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A
marker will be required to mark the maximum storage volume
for waste storage ponds.
22. Soil tests shall be made every two years and a liquid waste
analysis be taken at least twice each year consistent with
waste utilization plan. Poultry litter shall be tested prior
to application. Soil and waste analysis records shall be kept
for five years.
23. Dead animals will be disposed of in a manner that meets North
Carolina regulations.

Page 1
SOYBEAN/WHEAT ROTATION
WASTE UTILIZATION PLAN
------------------------
Producer-----:EDDIE JOHNSON County: ROBESON
Name of Farm -:FARM No2
Location ----- :905 WHITE POND RD WEST
FAIRMONT, NC 28340
Phone -------- :910 628-8396
Type Operation------------- WEAN TO FEEDER
Number of Animal ----------- . 3552
Storage Structure----------: Anaerobic Lagoon
Method of application---------: Irrigation
Amount of waste produced per year---------------. 1500 tons/year
Amount of plant available N (PAN) produced/year-: 1705 lbs_/year
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the
crops in the fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting
nutrient. Waste should be analyzed before each application cycle.
Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be
grown.
Several factors are important in implementing your waste
utilization plan in order to maximize the fertilizer value of the
waste and to ensure that it is applied in an environmentally safe
manner:
1. Always apply waste based on the needs of the crop to be grown
and the nutrient content of the waste. Do not apply more
nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall not be applied to land eroding at more
than 5 tons per acre per year. Waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on saturated soils, when it is raining, or
when the surface is frozen. Either of these conditions may
in runoff to the surface waters which is not allowed under DWQ
regulations.
5. Wind conditions should also be considered to avoild drift and
downwind odor problems.
6. To maximize the value of the nutrients for crop production and
to reduce the potential for pollution, the waste should be
applied to a growing crop or applied not more than 30 days
prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.

Page 2
This plan is based on the -waste application method shown above. If
you choose to change methods in the future, you need to revise
this plan. Nutrient levels for different application methods are
not the same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from
your waste management facility. In some cases you may want to have
plant analysis made, which could allow additional waste to be
applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content
and the crop type. Lime must be applied to maintain pH in the
optimum range for specific crop production.
This waste utilization plan, if carried out, meets the
requirements for compliance with 15A NCAC 2H .0217 adopted by the
Environmental Management Commission.

Page 3
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract
Field
Soil
Crop
Yield
Lbs. N
Lbs. N
Month to
No.
No.
Type
Code
/Acre
Unit Acres
Used
Apply
4069
1
NORFOLK
L
N/A
50.00.P
190.5
S-APRIL
4069
1
NORFOLK
C
6.1
50. 00 3d 3.8
1162.
MAR-OCT
4069
2
RAINS
L
N/A
500050
286
S-APRIL
4069
2
RAINS
C
4.5
50:00gj, 5.7
1287
MAR-OCT
4069
3
NORFOLK
W
60
2.40111
479.5
S-APRIL
4069
3
NORFOLK
O
32
4.006.7
853.7
JUN-SEP
4069
4
NORFOLK
W
60
2.40
411.8
S-APRIL
4069
4
NORFOLK
O
32
4.00r�i 5.7
732.1
JUN-SEP
Total 21.9
5403
Available
Nitrogen
(includes
commercial) 1705
Surplus
Or Deficit -3698
Crop codes: Crop -unit
A=Barley-bu.
B=Bermudagrass(graze)-tons
C=Bermudagrass(hay)-tons
D=Corn(grain)-bu.
E=Corn(silage)-tons
F=Cotton-lbs. lint
G=Fescue(graze)-tans
H=Fescue(hay)-tons
i=Oats-bu.
J=Rye-bu.
K=Small grain(graze)-acre
L--small grain(hay)-acre
M=Sorghum(grain)-cwt.
W=Wheat-bu.
Y=Fescue(pasture)-tons
Z=Bermudagrass(pasture)-tons
O=Soybeans-bu.
R=Matua(graze)-tons
U=Millet(graze)-tans
Applying the above amount of waste is a big job. You should plan
time and have appropriate equipment to apply the waste in a timely
manner.
The applicator is cautioned that P and K may be over applied while
meeting the N requirements. In the future, regulations may require
farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only
addresses nitrogen.
In interplanted fields (i.e. small grain, etc, interseeded in
bermudagrass), forage must be removed through grazing, hay and/or
silage. Where grazing, plants should be grazed when they reach a
height of six to nine inches. Cattle should be removed when plants
are grazed to a height of four inches. In fields where small drain
etc, is to be removed for hay or silage, care should be exercised
not to to let small drain to reach maturity, especially late in
the season (i.e. April or May). Shading may result if small grain
gets too high and this will definitely interfere with stand of
bermudagrass. This loss of stand will result in reduced yields and
less nitrogen being utilized. Rather than cutting small grain for
hay or silage just before heading as is the normal situation, you
are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the
season, depending on time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September

Page 4
or early October. Drilling is recommended over broadcasting.
Bermudagrass should be grazed or mowed to a height of about two
inches before drilling for best results.
Caution must be exercised in grazing or haying summer annuals
under stressed conditions. Nitrate poisoning may occur in livestock
Sampling forage or hay for nitrate levels is recommended.
Acres shown in the tables are considered to be the usable acres
excluding required buffers , filter strips along ditches, odd
areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the field listed may, and most likely will be, more than
the acres shown in the tables.
See attached map showing the fields to be used for the utilization
of animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provision for periodic
land application of sludge at agronomic rates. The sludge will be
nutrient rich and will require precautionary measures to prevent
over application of nutrients or other elements. Your production
facility will produce approximately 256 lbs. of plant available
nitrogen per year in the sludge.
If you remove sludge every 5 years, you will have approximately
1279 lbs. of PAN to utilize. assuming you apply this PAN to
hybrid bermudagrass hayland at the rate of 300 lbs. of nitrogen
per acre, you will need 4 acres of land. If you apply the
sludge to corn at the rate of 125 lbs. of nitrogen per acre, you
will need 10 acres of land. Please be aware that these are
only estimates of the PAN and land needed. Actual requirements
could vary by 25% depending on your sludge waste analysis, soil
types, realistic yields, and application methods.

Page 5
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate
of the soil at the time of irrigation such that runoff or ponding
occurs. This rate is limited by initial soil moisture content,
soil structure, soil texture, water droplet size, and organic
solids. The application amount should not exceed the available
water holding capacity of the soil at the time of irrigation nor
should the plant available nitrogen applied exceed the nitrogen
needs of the crop.
If surface irrigation is the method of land application for this
plan, it is the responsibility of the producer and irrigation
designer to ensure that an irrigation system is installed to
properly irrigate the acres shown in tables. Failure to apply the
recommended rates and amounts of nitrogen shown in the table may
make this plan invalid.
The following table is provided as a guide for establishing
application rates and amounts.
Applic Applic
Tract Field Soil Rate Amount
No. No. Type Crop (in/hr) (inches)
4069 1 NORFOLK CB HAY/SG 0.5 1.00
4069 2 CB HAY SG 0.4 1.00
4069 3 NORTOLK T SB 0.4 1.00
4069 4 NORFOLK WHT SB 0.4 1.00
This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations the application amount shown cannot be
applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180 days of temporary storage and
the temporary storage must be removed on the average of once every
6 months. In no instances should the volume of the waste be stored
in your structure be within the 25 year 24 hour storm storage or

Page 6
one foot of freeboard except in the event of the 25 year 24 hour
storm.
It is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply
the correct rates to the acres shown in the tables. Failure to
apply the recommended rates and amounts of nitrogen shown in the
tables may make this plan invalid.
Call your technical specialist after you receive the waste
analysis report for assistance in determining the amount of waste
per acre and the proper application rate prior to applying the
waste.
NARRATIVE OF OPERATION
THIS WUP HAS BEEN AMENDED TO SHOW WETTABLE ACRES. IRRIGATION
PARAMETERS ARE SHOWN ON FORM D-1. FIELDS 3,4 ARE IN A 2 YEAR
ROTATION OF WHEAT, SOYBEANS, CORN. THE YIELD FOR SO BEANS
HAS BEEN REDUCED BY 0 O 32 BU. TO ACCOUNT FOR LATE PLANTED
BEANS. ONE HALF OF THE W EA ACRES WERE USED FOR EACH YEAR OF
THE ROTATION. THESE ACRES DO NOT SHOW UP ON THE PLAN DUE TO
NATURE OF THE COMPUTER PROGRAM.

Page 7
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: FARM Not
Owner/Manager Agreement
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of
the waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
North Carolina Division of Water Quality (NCDWQ) before the new
animals are stocked. I (we) also understand that there must be no
discharge of animal waste from this system to the surface waters
of the state from a storm event less severe than the 25-year, 24-
hour storm. The approved plan will be filed on -site at the farm
office and at the office of the local Soil and Water Conservation
District and will be available for review by NCDWQ upon request.
Name of Facility Owner: EDDIE JOHNSON
(Please print)
signature: �2 ,. -- Date • %— o� j�`' f2%
Name of Manager(If different from owner):
Signature:
Name of Person Preparing Plan:
(Please print:)
Affiliation: Carroll's Foods, Inc.
Address: P O Drawer 855
Warsaw, NC 28398
Signature:
Date:
Howard Hobson
Phone: [phone]
Date: _ C,l Z_(j pj

Page 8
WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
EXHIBIT A-6
NRCS, NC
DUNE, 1996
1. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or direct
discharge during operation of land application. Any discharge
of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the producer
either owns or has a notarized agreement for use of adequate land
on which to properly apply the waste. If the producer does not own
adequate land to properly dispose of waste, he/she shall provide a
copy of a notarized agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen
needs for realistic crop yields based on soil type, available
moisture, historical data, climate conditions, and level of
management, unless there are regulations that restrict the rate
of application for other nutrients. Actual yields may be used in
lieu of realistic yield tables at the discretation of the planner.
4. Animal waste shall be applied on land eroding less than 5 tons per
acre per year. Waste may be applied to land that is eroding at more
than 5 tons but less than 10 tons per acre per year providing grass
filter strips are installed where runoff leaves the field.
(See FOTG Standard 393-Filter Strips)
5. Odors can be reduced by injecting the waste by disking after waste
application. Waste should not be applied when there is danger of
drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding,
it will be soil incorporated on conventionally tilled cropland.
When applied to conservation tilled crops or grassland, the waste
may be broadcast provided the application does not occur during
a season prone to flooding. (See "Weather and Climate in North
Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor and flies.
8. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste should be applied on actively growing crops in such
a manner that the crop is not covered with waste to depth that
would prohibit growth. The potential for salt damage from animal
waste should also be considered_
10. Waste nutrients shall not be applied in fall or winter for spring
planted crops on soils with a high potential for leaching. Waste
nutrient loading rates on these soils should be held to a minimum
and a suitable winter cover crop planted. to take up released
nutrients. Waste shall not be applied more than 30 days prior
to planting of a crop or forages breaking dormancy.

Page 9
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component
of a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after 10/1/95, shall
not be applied closer than 25 feet to surface water. This
distance may be reduced for waters that are not perennial pro-
vided adequate vegetative filter strips are present (See
Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet from wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animals waste shall not be discharged into surface waters,
drainageways or wetlands by a discharge or by over spraying.
Animal waste may be applied to prior converted cropland provided
it has been approved as a land applications site by a "technical
specialist". Animal waste applied on grassed waterways shall
be at agronomic rates and in a manner that causes no runoff or
drift from the site.
16. Domestic and industrial waste from washdown facilities, showers,
toilets, sinks, etc., shall not be discharged into the animal
waste management system.
17. A protective cover of appropriate vegetation will be established
on all disturbed areas (lagoon embankments, berms, pipe runs,
etc.). Areas shall be fenced, as necessary, to protect the
vegetation. Vegetation such as trees, shrubs, and other woody
species, etc. are limited to areas where considered appropriate.
Lagoon areas should be kept mowed and accessible. Lagoon berms
and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18. If animal production at the facility is terminated, the owner
is responsible for obtaining and implementing a "closure plan"
which will eliminate the possibility of an illegal discharge,
pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept
on site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption
it should only be applied preplant with no further applications
of animal waste during the crop season.
21. Highly visible permanent markers shall be installed to mark the
top and bottom elevations of the temporary storage (pumping
volume) of all waste treatment lagoons.' Pumping shall be
managed to maintain the liquid level between the markers. A
marker will be required to mark the maximum storage volume
for waste storage ponds.
22. Soil tests shall be made every two years and a liquid waste
analysis be taken at least twice each year consistent with
waste utilization plan. Poultry litter shall be tested prior
to application. Soil and waste analysis records shall be kept
for five years.
23. Dead animals will be disposed of in a manner that meets North
Carolina regulations.

0
100 SERIES BIG GUN - 240 TRAJECTORY - TAPER BORE NOZZLE
Nail. Nozcb
L40earm
-V
-GPM our
Ar
awe
ML
9z
s..
am
man%
ir
amt
hb=b
r
am om
I so
47
55
64
n
IN 5T -2v
66 213'
.01 241Y
Ma
106
re
AMMUNho
96
w:
23
222—
,
2OW-u
YTS
M
91
211MON069
125
143
2W
30S
103 2W
lie 25M
IN 2W
152
ZINEXIMM
W 146 2
��
143 1
- --
1 185 3w
MMOMMM
I log 314'
ge IN
25C
00 ze 2w100
1133 3w
Jos
212 33F
= 3w
150 R Rim, Nozzles - US urds
�a�e-55 RinR 97
1 1.25 F;bng
- _1.34 R!ng
1.41 RiV
EAA �GPLJ
--7
DtA
GPM
Rik
PM
DIA GPM
DIA
GPM
NA
GPM
-DtA
50 100
-
245 130
m
1w
285
7 205
300 255
320
300
335
'350
350
cio�ilo
2613 1143
280
182
300
-.225
315 275
335
i 330
350
.305
365
70:120
270 �155
290
1127
310
. '245
330 :205
350:355
365
�415
380
2W 1ti5
300
320
:250
340 '.315
360
380
300
445
395
90'135
- - - -------- -
290 '175
310
�223
330
:275
3w ;33s
37 0
405
390
.475
405
400 143 300 id!)
320
'235
340
:290
36C 355
3w
.425
40*
500
415
110 150
310 195
330
247
350
'305
370 370
390
'445
410
'525
425
120 157
:51b -.204
335
i2m
380
'AM 305
400
-465
420
546
435

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
Michael F. Easley, Governor
Sherri Evans -Stanton, Acting Secretary
Kerr T. Stevens, Director
EDDIE JOHNSON
EDDIE JOHNSON #2
905 WHITE POND ROAD WEST
FAIRMONT NC 28340
ATTN: EDDIE JOHNSON
Dear Eddie Johnson:
I IT Y
1 WC-5NCDENR
•
f
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT ANo NATURAL RESOURCES
HL ENU
January 9, 2001
rJAN 1 ? 2001
FAYET/TEVILLE
R
Subject: Application No. AWS780087
Additional Information Request
Eddie Johnson #2
Animal Waste Operation
Robeson County
The Non -Discharge Permitting Unit has completed a preliminary engineering review of the
subject application. Additional information is required before we can continue our review. Please
address the following by February 8, 2001:
Please sign and date the enclosed application of waste by irrigation sheet. This is needed to
verify you have read and understood the additional documentation to your current waste
utilization plan. This change was made by Mr. Howard Hobson, Technical Specialist, on
your behalf. Please note that all WUP revisions must be signed and dated by both the
owner and the technical specialist. Please return this signed and dated page to our office,
before February 8, 2001.
Please reference the subject permit application number when providing the requested
information. All information should be signed, sealed, and submitted in duplicate to my attention at the
address below.
NCDENR-Non Discharge Permitting Unit (attn. Theresa Nartea)
1617 Mail Service Center
Raleigh, North Carolina 27699-1617
The information requested by this letter must be submitted on or before February 8, 2001 or the
Division will return your application as incomplete in accordance with 15A N.C.A.C. 2H .0200 and your
facility will be considered to be operating without a permit.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Application No, 78-0087
Eddie Johnson
Page 2
Please be advised that operation of the subject animal waste management system without a valid
permit is a violation of North Carolina General Statute 143-215.1 and will subject you to the
enforcement authority of the Environmental Management Commission.
If you have any questions regarding this request, please call me at [phone], ext. 375.
Sincerely,
Theresa Nartea
Soil Scientist
Non -Discharge Permitting Unit
cc: Fayetteville lteanan®ff"ce, iNaQuality
Permit File

r
State of North Carolina
Department of Environment
and Natural Resources ®����
Division of Water Quality r i VED
Michael F. Easley, Govemor
William G. Ross, Jr., Secretary
EDDIE JOHNSON
EDDIE JOHNSON #2
905 WHITE POND ROAD WEST
FAIRMONT NC 28340
Dear Mr. Johnson:
VAR 7 2M
�• �, r- ITEVILLE
REG. OFFICE
-1.
February 21, 2001
3W
A4;,LA
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RzsouRcES
Subject: Certificate of Coverage No. AWS780087
Eddie Johnson #2
Swine Waste Collection, Treatment,
Storage and Application System
Robeson County
In accordance with your application received on November 6, 2000, and additional information
response, received January 26, 2001; we are forwarding this Certificate of Coverage (COC) issued to
Eddie Johnson, authorizing the operation of the subject animal waste collection, treatment, storage and
land application system in accordance with General Permit AWG 100000. This approval shall consist of
the operation of this system including, but not limited to, the management of animal waste from the
Eddie Johnson #2, located in Robeson County, with an animal capacity of no greater than 3552 Wean to
Feeder swine and the application to land as specified in the Certified Animal Waste Management Plan
(CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations
as specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
The facility's CAWMP meets all requirements in place at the time of certification. However, it
appears that the irrigation system on site may not adequately cover all acreage listed in the Waste
Utilization Plan. The owner should address this inconsistency as soon as possible.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Certificate of Coverage AWS780087
Eddie Johnson #2
Page 2
Please be advised that any violation of the terms and conditions specified in this COC, the General
Permit or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS
143-215.6A through 143-215.6C including civil, penalties, criminal penalties, and injunctive relief.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This
request shall be made within 30 days of notification by the Division.
This COC is not automatically transferable. A name/ownership change application must be
submitted to the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the
right to apply for an individual non -discharge permit by contacting the engineer listed below for
information on this process. Unless such a request is made within 30 days, this COC shall be final and
binding.
The subject farm is located in the Fayetteville Regional Office. The Regional Office Water
Quality Staff may be reached at [phone]. I€ you need additional information concerning this
COC or the General Permit, please contact Theresa Nartea at [phone] ext. 375.
ZS' ely,
1
rr T. Stevens
cc: (Certificate of Coverage only for all cc's)
Robeson County Health Department
F.a" yetteville Regioi�ai-Office,_ Water Quality Section
Robeson County Soil and Water Conservation District
Permit File
NDPU Files

1
State of North Carolina
Department of Environment and Natural Resources
Division of Water Quality R8CE1VED
Non -Discharge Permit Application Form
(THIS FORM MA Y BE PHOTOCOPIED FOR USE AS AN ORIGIN4 y 0 6 2000
General Permit - Existing Animal Waste mPALnY SECTION
Nor-DischjW� i
The following questions have been completed utilizing information on file wi I-gon. Please
review the information for completeness and make any corrections that are appropriate. If a
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
L GENERAL INFORMATION:
1.1 Facility Name: Eddie Johnson #2
1.2 Print band Owner's name: Eddie Johnson
1.3 Mailins address: 905 White Pond Road West
City, State: Fairmont NC Zip: 28340
Telephone Number (include area code): 910-628-8396
1.4 County where facility is located:
I.5 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a copy
of a county road map with the location of the farm identified): On the southeast side of SR 2482 approx.. .3 miles northeast
of intersection with SR 2479. southeast of Fairmont. NC.
1.6 Print Farm Manager's natne (if different from Land Owner):
1.7 Lessee's / Integrator's name (if applicable; please circle which type is listed): Car -roll's Foods. Inc_
1.8 Date Facilitv Originally Began Operation:
1.9 Date(s) of Facility Expansion(s) (if applicable):
2. OPERATION INFORMATION:
2.1 Facilitv No_: 78_ (county number); 87 (facility number).
2.2 Operation Description: Swine operation
Wean to Feeder
3552- Certified Design Capacity
Is the above information correct? F21 yes, F� no. If no. correct below using the design capacity of the facility
The "No. of Animals" should be the maximum number for which the waste management structures were designed.
Type of Swine
0 Wean to Feeder
0 Feeder to Finish
0 Farrow to Wean (# sow)
0 Farrow to Feeder (# sow)
0 Farrow to Finish (# sow)
No. of Animals Type of Poultty No. of Animals
Other Type of Livestock on the farm:
0 Laver
0 Non -Layer
0 Turkey
Type of Cattle No. of Animals
0 Dairy
0 Beef
No. of Animals:
FORM: AWO-G-E 7n199
Page 1 of 4 78 - 87

3.
2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): 13 : Required Acreage (as listed in the AWMP): 6.2
2.4 Number lagoo storage ponds (circle which is applicable):
2.5 Are subsurface drains present within 100' of any of the application fields'? YES or '� (please circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES or (1�0:) (please circle one)
2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, NRCS Standards, etc.) (Swine Only)
YES or NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited'? 70 - �;(o
What was the date that this facility's land application areas were sited? 7` J - q (y
REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
Applicants Initials
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations-,
3 2 Two copies of a general location map indicating the location of the animal waste facilities and r 1
field locations where animal waste is land applied; G la
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit application r
for animal waste operations. L Gt
The CAWMP must include the following components. Some of these components may nor
have been required at the time the facility was certif ed but should be added to the
CAWMP for permitting purposes:
33.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.33 A map of every field used for land application.
3.3.4 The soil series present on every land application field.
3.3.5 The crops Crown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application field.
3.3.8 The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.3.10 A site schematic.
3.3.1 1 Emergency Action Plan.
3.3.12 Insect Control Checklist with chosen best management practices noted.
3.3.13 Odor Control Checklist with chosen best management practices noted.
3.3.14 Mortality Control Checklist with the selected method noted.
3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility.
3.3.16 Operation and Maintenance Plan.
If your CAWMP includes any components not shown on this list. please include the
additional components with your submittal.
FORM: AWO-G-E 7/7/99 Page 2 of 4 78 - 8'7

Facility Number: 78 - 87
Facility Name: Eddie Johnson #2
4. APPLICANT'S CERTIFICATION:
1, 106_doi C, JOA,0,50 r] (Land Owner's name listed in question 1.2), attest that
this application for _ .Edd �c , '1 o A0 cart 'y 2— _ (Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be returned to me as ijw_Qmplete.
Signature
Date _/_00
5. MANAGER'S CERTIFICATION: (complete only if different from the Land Owner)
(Manager's name listed in question 1.6), attest that this
application for (Facility name listed in question 1_1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be returned as incomplete.
Signature
Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS.
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMIITTING UNIT
1617 MAIL SERVICE CENTER
RALEIGH, NORTH CAROLINA 27699-1617
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
FORM: AWO-G-E 7I7I99 Page 3 of 4 78 - 87

EL �
� r /Q
RECEIVED
M EMOR"I4dU M
WATER QUALITY SECTION
on- Esc ,P
DATE: January 28, 1998
TO: All NC Contract Growers - Sow, Nursery, and Finisher
CC: M. Miller, T. Jones, L. Stutts
FROM: Peter Moss
SUBJECT: Lagoon and Waste Management -January, 1998
We have, right now, a very difficult situation on our hands, what with the high
rainfall, high level of lagoons, and water sodden spray fields. Though we have very
few opportunities in the immediate future, the following advise may help get you
through these tough times:
1. Please read the attached Emergency Action Plan. If you want to add soil to raise
the level of the dam of the lagoon, make an assessment of what damage may occur
to the dam from moving tractors, machinery, etc., which may weaken the dam and
set up an even larger problem. Sand bags may be the best solution in some cases.
2. For those of you who have spillways as an engineered part of the lagoon, then you
could do the following in case of an emergency. Contact DWQ and let them know
that you wish to put a tee dam across the spillway because of dire
circumstances. Get their approval and either place dirt, soil, or sand bags in the
spillway area. A thorough inspection of the dam wall by DWQ and yourself before
doing this is a must, as any weakness in the wall will be accentuated by raising the
lagoon level.
3. if there is less than 19" of freeboard (12" freeboard, 7" 25 yr. storm) on your lagoon,
then y_gu are required to notify the Division of Water Quality_ I would suggest
contacting them if the lagoon level gives you less than 19" of freeboard and you
cannot spray on your field(s). There are two district offices for our entire operating
area:
• Mr. Holzinger; Wilmington, NC 910-395-3900 (Brunswick and Columbus
Counties)
• Grady Dobson, Fayetteville, NC 91 OA86-1541 (All other counties)
Furthermore, you must always notify them of any spill - be it from the lagoon
breaching or from excess spray application running off the field(s). In both these
cases, you also need to let Carroll's know of the problem and attempt to dam up the
spillage to prevent it from crossing your property line.

Lagoon and Waste Management - January 1998
January 28, 1998
Page 2
4. Use every opportune day to spray waste. A reduction in orifice nozzle size would
reduce the volume put out by your gun. Apply more often but in less amounts (3/10"
- 5/10" per acre max. with lower amounts on heavier land).
5. Operate off the start pumping pipe over the next two months. If it is above the start
pumping top pipe, spray until you can get the level a couple of inches below the top
pipe. When the weather and season improve, make sure that you work between the
middle and bottom pipes.
6. Once you have the pumps running and are spraying, take time to walk the -field to
make sure there is no run-off. This is more important for those of you with steep
gradients on your land.
7. Check to make sure that there are no water leaks in your buildings. One dripping
nipple drinker in each of your houses can add thousands of gallons of water to your
lagoon over a short period of time.
8. If you have pull -plug buildings, then increase the interval between pulls (say from 4
days to every 7 to 10 days).
P_0_� kt',�
Peter Moss
Attachment

EMERGENCY ACTION PLAN
PHONE NUMBERS
DIVISION OF WATER QUALITY (DWQ) CFGycf�G�:lle) _qip=_41F4-1541
EMERGENCY MANAGEMNET SERVICES (EMS) 67/-3,1s0
SOIL AND WATER CONSERVATION DISTRICT (SWCD) Z -5117Y
NATURAL RESOURCES CONSERVATION SERVICE (NRCS) 7& y - s5yTf
COOPERATIVE EXTERSION SERVICE (CES) G Z/-_3.A7Ca
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing or running off site. You should not wait until wastes reach surface waters
or leave you property to consider that you have a problem. You should make every
effort to ensure that this does not happen. This plan should be posted in an accessible
location for all employees at the facility. The following are some action items you should
take,
1 , Stop the release of wastes. Depending on the situation, this may or may not be
possible. Suggested responses to some possible problems are listed bel*W.
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to. the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B. Runoff from waste application field -actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that cause the runoff.
e. Evaluate the application rates for the"fields where runoff occurred.
C. Leakage from the waste pipes and sprinklers -action include:
a, Stop recycle pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
D. Leakage from flush systems, houses, solid separators -action include:
a_ Stop recycle pump.
b. Stop irrigation pump.
c. Make sure siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed
to flowing leaks -possible action:
a. Dig a small sump or ditch from the embankment to catch all
seepage, put in a submersible pump, and pump back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon
bottom as soon as possible,

2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what duration?
c. Any damage notes, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours call your DWQ regional office; Phone - -. After
hours, emergency number: 919-733-3942, Your phone call should include; your
name, facility number, telephone number, the details of the incident from item 2
above, the exact location of the facility, the location or direction of movement of
the spill, weather and wind conditions. The corrective measures that have been
under taken, and the seriousness of the sitution.
b- if spill leaves property or enters surface waters, call local EMS phone number.
c. Instruct EMS to contact local Helath Department.
d. Contact CEs, phone number - , local SWCD office phone number - -, and local
NRCS office for advice/technical assistance phone number - -.
4. if none of the above works call 911 or the Sheriff's Department and explain you
problem to them and ask the person to contact the proper agencies for you.
5. Contact the contractor of your choice to begin repair or problem to minimize off —
site damage.
a. Contractors Name: I rnrn� L f c!iu r _
b, Contractors Address: . F'ai`�r rn, __ .
c. Contractors Phone: - i 24
6. Contact the technical specialist who certified the lagoon (NRCS, Consulting
Engineer, etc.)
a. Name: HQalgd- r4cbsen _ -
b. Phone: 5110- =-�93 -34.34
7. Implement procedures as advised by DWQ and technical assistance agencies to
rectify the damage, repair the system, and reassess the waste managmenT plan to
keep problems with release of wastes from happening again,
Z

Animal Waste Management Plan Certification
(Please type or print all information that does not require a signature)
E©rQ or x.. nde'leas'crcfe�onevrunw
General Information:
Name of Farm: F�a + S og s6 � ftnv 0 t��t-1 ?rI ° z- Facilit�N O.
Owner(s) Name: Etit�1 E T ►+Ks6K PjNbi+ i YyT1013 s
Mailing Address: RT— I Brno *4- 3 , Fa toMowr- , rl •C- �Z8,34 Non-Discha'9- PefMIUI'
Farm Location: Fourteen Digit Hydrologic Unit:_ v3o4 oZ- 3 I g ao 6a
Latitude and Longitude: „�4a 26� .�S .NI 79 • oQ , 3a rW County:'-�$�so�
Please attach a copy of a county road map with location identified and describe below (Be specific: road
names, directions, milepost, etc-): F+� rs ,rep Aapea x. _.3. o M tLe5_ We_s-- a F fir• Q F
N c 4-1 4 ri C y - -. . FaRm Ts A99Rmx. .4..0n0' its rs s= Nc 9 04 c*4 FARM Rirf+.
QpCrafionri i n:
Type of Swine No. of Animals Type of Poultry No. of Animals Type of Cattle
Ur*ean to Feeder :ns55:- t7 Layer a Dairy
❑ Feeder to Finish ❑ Pullets ❑ Beef
❑ Farrow to Wean
U Farrow to Feeder
❑ Farrow to Finish
Acreage Available for Application:
No. of animals
Other Type of Livestock: Number of Animals:.
1-.5
Required Acreage
rQ . 7.
Number of Lagoons / Storage Ponds : I Total Capacity: �43, 93S Cubic Feet (ft-)
Are subsurface drains present on the farm: YES or NO (please circle one)
Owner / Manager Agreement
I (we_) verify that all the above i-Zfcraration is correct and will be mpkiated I.- rhanaina T fvlP) ^.derm-nd the nY ��inn �nr�
r_..a...�. - .
maintenance procedures established in the approved animal waste management plan for the farm named above and will
implement these procedures. I (we) know that any expansion to the existing design capacity of the waste treatment and
storage system or construction of new facilities will require a new certification to be submitted to the Division of
Environmental Management before the new animals are stocked. I (we) understand that there must be no discharge of animal
waste from the storage or application system to surface waters of the state either directly through a man-made conveyance or
from a storm event less severe than the 25-year, 24-hour storm and there must not be run-off from the application of animal
waste. I (we) understand that run-off of pollutants from lounging and heavy use areas must be minimized using technical
standards developed by the Natural Resources Conservation Service. The approved plan will be filed at the farm and at the
office of the local Soil and Water Conservation District. I (we) know that any modification must be approved by a technical
specialist and submitted to the Soil and Water Conservation District prior to implementation. A change in land ownership
requires written notification to DEM or a new certification (if the approved plan is changed) within 60 days of a title transfer.
Name of Land Owner: EUDtE�N
Signature:
Date: '?_ —� — %r,�_
Name of Manager(if different from owner):
Signature: Date:
ANVC -- April 24, 1996

N
Technical Specialist Certification
I. As a technical specialist designated by the North Carolina Soil and Water Conservation Commission
pursuant to 15A NCAC 6F .0005, I certify that the animal waste management system for the farm
named above has an animal waste management plan that meets or exceeds standards and specifications
of the Division of Environmental Management (DEM) as specified in 15A NCAC 2H.0217 and the
USDA -Natural Resources Conservation Service (NRCS) and/or the North Carolina Soil and Water
Conservation Commission pursuant to 15A NCAC 2H.0217 and 15A NCAC 6F .0001-.0005. The
following elements are included in the plan as applicable. While each category designates a technical
specialist who may sign each certification (SD, SI,. WUP, RC, I), the technical specialist should only
certify parts for which they are technically competent.
M- IL Certification of Design
A) Collection, Storage. Ireatment System
Check the appropriate box
0 Existing facility without Mrmfit (SD or WUP)
Storage volume'is adequate for operation capacity; storage capability consistent with
waste utilization ren iren;ents.
BNew, expanded or retrofitted facility ($D)
Animal waste storage and treatment structures, such as but not limited to collection systems,
lagoons and ponds, have been designed to meet or exceed the minimum standards and
specifications.
r
Name of Technical Specialist (Please nt .
Affiliation: _ - m FLzgO &pAs�
Address(Agency): Po, Aw, to9g- Phone No.: `3ia •z9 - t t1!,
Signature: / _I Date: Z ! 3 a / }S
- rT a
B) Lud AQi?Uotion Site (WUP) `��r �, 'V
The plan provides for minimum separations (buffers); adequate amount of land for waste
utilization; chosen crop is suitable for waste management; hydraulic and nutrient loading rates.
Name of Technical Specialist (Please Print): 1-6WAR,-D L�2 E!Sr- 4
Affiliation: 2ARRau-_'5 1:7D oZ>s , SK c.
Address(Agency): -9 a Sax 856 , WAPP;AW . K C• 2 39 S _ Phone No-. Qto zQ3-3¢311-
Signature: _ ` Q,—Q- g _ Date: 7/3/96
C) Runoff Controls from Exterior Lots
Check the appropriate boz
il" Facility without exterior lots (SD or WUP or RC)
This facility does not contain any exterior lots.
❑ Facility with exterior lots (RC)
Methods to minimize the run off of pollutants from lounging and heavy use areas have been
designed in accordance with technical standards developed by NRCS.
Name of Technical Specialist (Please Print): 46 mot} 4c)85or(
Affiliation: r4aocLc. F2)cD_-,Z Mkr-.
Address(Agency): P.a. Bvx 85L ARSAY4 C. as39 s Phone No.: ,t, - 43¢
Signature:_ _4OLa__C_)_ d. _ - -- Date: 6
AWC -- April 24, I996

R .
D) Aj2oiication and Handling Eauiflment
Check the appropricre box
0 Existing facility with existing waste application equipment (WUP or I)
Animal waste application equipment specified in the plan has been either field calibrated or
evaluated in accordance with existing design charts and tables and is able to apply waste as
necessary to accommodate the waste management plan: (existing application equipment can
cover the area required by the plan at rates not to exceed either the specified hydraulic or
nutrient loading rates, a schedule for timing of applications has been established; required
buffers can be maintained and calibration and adjustment guidance are contained as part of the
plan).
❑ New or expanded facilitvi or existing facility without existing waste application -equipment (1)
Animal waste application equipment specified in the plan has been designed to apply waste as
necessary to accommodate the waste management plan; (proposed application equipment can
cover the area required by the plan at rates not to exceed either the specified hydraulic or
nutrient loading rates; a schedule for tithing of applications has been established; required
buffers can be maintained; calibration and adjustment guidance are contained as part of the
plan).
Name of Technical Specialist (Please Print): wAal) t�oB5oN 1�Ic1�
Affiliation:_( e?AZ&cLC ilc-03; .1�{•
Address(Agency): /D. 30x 8561WWSRLc! ,Its• C• -2e3!2$ Phone No.:p/o
Signature:_ Date: Z// 2 A26
III. Certification of Installation
A) Collection, Storage, Treatment InsIgligtion
ew expanded or retrofitted facility (Sl)
Animal waste storage and treatment structures, such as but not limited to lagoons and ponds,
have been installed in accordance with the approved plan to meet or exceed the minimum
standards and specifications.
For existing facilities without retrofits, no certification is necessary.
Name of Technical Specialist (Please Pgnt.'�... •� —i�ovt
Affiliation: _ M _� c�y� AoA; -sIrl—
Address(Agency): k, 0 ,_wit -' Phone No.: to - -7
Signature: Date: 1.14
/ 9 7
� _ a
AWC -- April 24, 1996

r
B) Land Annlication Site (WUP)
Check the appropriate box
:3 The cropping system is in place on all land as specified in the animal waste management plan.
Conditional Approval: all required land as specified in the plan is cleared for planting; the
cropping system as specified in the waste utilization plan has not been established and the
owner has committed to establish the vegetation as specified in the plan by MAy 3Q, ! 47
(month/day/year); the proposed cover crop is appropriate for compliance with the waste
utilization plan.
❑ Also check this box if appropriate
if the cropping system as specified in the plan can not be established on newly cleared
land within 30 days of this certification, the owner has committed to establish an interim
crop for erosion control; L,.ud wt,, 64- ? kFL C-iMA A tr--Ad\.J v-o �N— f h 0 t f o b �
a IAkl Lid
Name of Technical Specialist (Please Print):_ anw im
Affiliation: 04411aCi s T;�o p 2. :3�4 c -
Address(Agency): AD- bc�c 65 (� , VJA SAw , tk- c . -7-6 32 B -- -- -- --phone No.: 4/Z)
Signature: 4J�G-3 -- - -- — --Date:_ z/3196
This following signature block is only to be'used when the box for conditional approval in III. B
above has been checked.
I (we) certify that I (we) have committed to establish the cropping system as specified in my (our) waste
utilization plan, and if appropriate to establish the interim crop for erosion. control, and will submit to
DEM a verification of completion from a Technical Specialist within 15 calendar days following the date
specified in the conditional certification. I (we) realize that failure to submit this verification is a
violation of the waste management plan and will subject me (us) to an enforcement action from DEM.
Name of Land Owner: >D! E a nH rc 5cn1
Date:_ 'V— 9�
Name of Manager(if different from owner):
Signature: Date:
C) Ruwff_Controls from Exterior Lots (RC)
Facilitv with exterior lots
Methods to minimize the run off of pollutants from lounging and heavy use areas have been
installed as specified in the plan.
For facilities without exterior lots, no certification is necessary.
Name of Technical Specialist (Please Print):
Affiliation:
Address (Agency): Phone No..
Signature: Date:
AWC -- April 24, 1996 4

aw
D) Aw2lication and Handlingi n ll ion (WUP or I)
Check the appropriate block
Animal waste application and handling equipment specified in the plan is on site and ready
for use; calibration and adjustment materials have been provided to the owners and are
contained as part of the plan.
❑ Animal waste application and handling equipment specified in the plan has not been
installed but the owner has proposed leasing or third party application and has provided a
signed contract; equipment specified in the contract agrees with the requirements of the
plan; required buffers can be maintained; calibration and adjustment guidance have been
provided to the owners and are contained as part of the plan.
Or" Conditional approvalAnimal waste application and handling equipment specified in the
plan has been purchased and will be on site and installed by 199 -7
(month/day/year); there is adequate storage to hold the waste until the equipment is installed
and until the waste can be land applied in accordance with the cropping system contained
in the plan; and calibration and adjustment guidance have been provided to the owners and
are contained as part of the plan.
Name of Technical Specialist (Please Print): —1_-6wAf-o 4ce5a�t _
Affiliation: C' A ems 'F- o D s , = K c .
Address (Agency): P.o. t3er, ash, 1er A R5A W , N. C. 2-a3 98 Phone vo.: 9to :2,93 -34 3<I-
Signature: -4 .4-- - Date: �1 9
The following signature block is'only to be used when the box for conditional approval in III D
above has been checked.
I (we) certify that I (we) have committed to purchase the animal waste application and handling
equipment as specified in my (our) waste management plan and will submit to DEM a verification of
delivery and installation from a Technical Specialist within 15 calendar days following the date specified
in the conditional certification. I (we) realize that failure to submit this verification is a violation of the
waste management plan and will subject me (us) to an enforcement action from DEM.
Name of Land Owner: l7 na iE o
Signature:—
Date: 2 - .f ~ 9,)
Name of Manager(if different from owner):
Signature: Date:
Please return the completed form to the Division of Environmental Management at the
following address:
Department of Environment, Health, and Natural Resources
Division Of Environmental Management
Water Quality Section, Compliance Group
P.O. Box 29535
Raleigh, NC 27626-0535
Please also remember to submit a copy of this form along with the complete Animal Waste
Management Plan to the local Soil and Water Conservation District Office and to keep a copy in
your files with your Animal Waste Management Plan.
AWC -- April 24, 1996

Animal Waste Management Plan Certification
ATTACIUNENT A
I4
FORM AWC -- APRIL 24. 1996
General Information:
Name of Farm: E�)DtE Jot+,,Lse&A N vz Facility No: -
Owner(s) Name: 1~ Dn ig St+145&,A _ . Phone No: 91V C ZS — e3 96
Mailing Address: RT- 1
H. Certification of Design
D),Application- and Handling Equipment
New or opanded facility, or existing facility with ut exi tins wa5te-applicarion
ui m n ()VU-P or I)
Animal waste application equipment specified in the plan has been either field
calibrated or evaluated in accordance with existing design charts and tables and
is able to apply waste as necessary to accommodate the waste management plan:
(application equipment can cover the area required by the plan at rates not to
exceed either the specified hydraulic or nutrient loading rates, a schedule
for timing of applications has been established; required buffers can be
maintained and calibration and adjustment guidance are contained as part of the
plan).
Name of Technical Specialist (Please Print): 44y1u.mn 4bs5o,4
Affiliation: Q4 cc's Ti�,ob5 ,
Address(Agency): D.o.8i�K 93% , WnZxAV-t , nC. Phone No.: a Zq3- 34-
Sib ature: ` � _...- -- Date: 71-d s ._
If the technical specialist chooses to use this Attachment to certify the design of a
new or expanded facility; or existing facility without existing waste application
equipment, it must be attached to the completed Animal Waste Management
Certification Form (AWC- April 24, 1996). The technical specialist must also write
in the words "See Attachment" in Part II. D. of the Certification Form to notify the
review agencies that the Attachment has been used.
This Attachment will not be acceptable past the effective date of the new NRCS
Technical Standards.
AWC(A) -- May 3, 1996

Swine Farm Waste Management Odor Control Checklist
Source Cause BMI's to Minimize Odor Site Specific Practices
Farmstead C Swine production
Vegetative or wooded buffers
❑ Recommended best management practices
❑ Good judgment and common sense
Animal body Y Dirty manure -covered I' Dry floors
surfaces animals
Floor surfaces o Wet manure -covered floors Slotted floors
f " Waterers located over slotted floors
❑ Feeders at high end of solid floors
R"' Scrape manure buildup from floors
❑ Underfloor ventilation for drying
Manure collection 0 Urine 2' Frequent manure removal by flush, pit recharge,
pits c partial microbial or scrape
decomposition ❑ Underfloor ventilation
Ventilation exhaust O Volatile gases Fan maintenance
fans o Dust G3� Efficient air movement
Indoor surfaces o Dust Or Wastidown between groups of animals
❑ reed additives
❑ feeder covers
❑ Feed delivery downspout extenders to feeder
covers
Flush tanks o Agitation of recycled lagoon ❑ Flush tank covers
liquid while tanks are filling ❑ Extend fill lines to near bottom of tanks with
anti -siphon vents

Swine Farm Waste Management Odor Control Checklist
Source Cause ]3MI's to Minimize Odor Site Specific Practices
Flush alleys Agitation during wastewater GO,"' Underfloor f LISII witll underfloor vetltilation
conveyance
Pit recharge points • Agitation of recycled lagoon O Extend recharge litres to near bottom of l)its with
liquid while pits are filling anti -siphon vents
Lift stations • Agitation during sump tank O Sump tank covers
filling and drawdown
Outside drain • Agitation during wastewater 0 Box covers
collection or conveyance
junction boxes
End oi'drainpipes • Agitation during wastewater Extend discharge point of pipes underneath
at lagoon conveyance lagoon Iiquid level
Ligoon surfaces • Volatile gas emissions Proper lagoon liquid capacity
• Biological mixing O Correct lagoon startup procedures
Agitation Cl Minimum surface area-to=volume ratio
PiMinirnum agitation when pumping
O Mechanical aeration
O Proven biological additives
Irrigation sprinkler • High pressure agitation Irrigate on dry days with little or no wind
nozzles . Wind drift Cl Mlrllnlunl recommended operating pressure
dPump intake near lagoon liquid surface
0 I'tlnlp from second -stage lagoon

r
Swine Farm Waste Management Odor Control Checklist
Source Cause BMI's to Minimize Odor Site Specific Practices
Manure tracked onto o Poorly maintained access lr Farm access road maintenance
public roads from roads
farm access
Additional Information; Available From;
Swine Manure Management; .0200 Rule/BMP Packet NCSU, County Extension Center
Swine Production Farm Potential Odor Sources and Roniedies; EBAE Fact Sheet NCSU—BAE
Swine Production Facility Manure Management: Pit Recharge ---Lagoon Treatment; EBAE 128-88 NCSU—BAE
Swine Production Facility Manure Management: Underfloor Flush --Lagoon Treatment; EBAE 129-88 NCSU--BAE
Lagoon Design and Management for Livestock Manure Treatment and Storage; EBAE 103-83 NCSU—BAE
Calibration of Manure and Wastewater Application Equipment; EBAE Fact Shect NCSU—BAE
Controlling Odors from Swine Buildings; PII-I-33 NCSU—Swine Extension
Environmental Assurance Program; NPPC Manual N.C. Pork Producers Assoc.
Options for Managing Odor; a report from the Swine Odor Task Force NCSU Agricultural Communications
Nuisance Concerns in Animal Manure Management: Odors and Plies; PRO107, 1995 Conference Proceedings Florida Cooperative Extension

Insect Control Checklist for Animal Operations
Source Cause BMI's to Control Insects Site Specific Practices
Deed storage • Accumulations of feed Reduce moisture accumulation within and around
residues immediate perimeter of feed storage areas by
ensuring drainage is away from site and/or
providing adequate containment (e.g., covered bin
for brewer's grain and similar high moisture grain
products)
❑ Inspect for and remove or breakup accumulated
solids in filter strips around feed storage as needed
Animal Bolding • Accumulations of animal ❑ Eliminate low areas that trap moisture along fences
areas wastes and feed wastage and other locations where waste i1CCuniulatcs and
disturbance by animals is minimal
❑ Maintain fence rows and filter strips around animal
Bolding areas to minimize accumulations of wastes
(i.e., inspect for and remove or break up
accumulated solids as needed)
Dry manure + Accumulations of animal ❑ Remove spillage on a routine basis (e.g.,
handling systems wastes 7- to I0-day interval during summer; 15- to 30-day
interval during winter) where manure is loaded for
land application or disposal
❑ Provide for adequate drainage around manure
stockpiles
❑ Inspect for and remove or break up accumulated
wastes in filter strips around stockpiles and manure
handling areas as needed
For more information contact:
Cooperative Extension Service, Department of Entomology, Box 7613, North Carolina St.►te university, Raleigh, NC 27695-7613.

Insect Control Checklist for Animal Operations
Source Cause BMPs to Control Insects Site Specific Practices
Flush gutters • Accumulation of solids
Lagoons and pits • Cnisted solids
Excessive vegetative • Decaying vegetation
growth
Feeders • Teed spillage
Liquitl Systems
0 Fluslt system is designed and operated
sufficiently to remove accumulated solids from
gutters as designed
CI Remove bridging of accumulated solids at
discharge
Cl Maintain lagoons, settling basins and pits where
pest breeding is apparent to minimize the crusting
of solids to a depth of no more than G to 8 Inches
over more than 30 percent of surface
Maintain vegetative control along batiks of
lagoons and other impoundments to prevent
accumulation of decaying vegetative matter along
water's edge on impoundment's perimeter.
Dry Systents
O Design, operate, and maintain feed systems
(e.g., bunkers and troughs) to minimize the
accumulation of decaying wastage
D Clean up spillage on a routine basis (e.g., 7- to 10-
day interval during stunnter; 15- to 30-day interval
during winter)

IL
Mortality Management Methods
(check which method(s) are being implemented)
%
Q Burial three feet beneath the surface of the ground within 24 hours after
knowledge of the death. The burial must be at least 300 feet from any flowing
/ stream or public body of water.
U Rendering at a rendering plant Iicensed under G.S. 106-168.7
❑ Complete incineration
❑ In the case of dead poultry only, placing in a disposal pit of a size and design
approved by the Department of Agriculture
❑ Any method which in the professional opinion of the State Veterinarian would
make possible the salvage of part of a dead animal's value without endangering
human or animal health. (Written approval of the State Veterinarian must be
attached)
December 18, 1996

A
-)LAu q° 1
CJ'� 1 ttFi
WASTE UTILIZATION PLAN
----------------------
Owners name--:EDDIE JOHNSON
Mail Address-:RT 1, BOX 443, FAIRMONT, NC
Type of production unit ---- :WEAN -FEED
Number of animal units-----: 3552
County:ROBESON
Type of waste facility ----- :Anaerobic Lagoon
Temporary storage period---: 180 days
Method of application ------ :IRRIGATION
Amount of animal waste produced-----------------: 1500 tons/year
Amount of plant available N produced by animals-: 1705 lbs./year
Commercial N to apply on planned acreage--------: 0 lbs./year
Your animal waste utilization plan has been specifically
developed for your swine operation. The plan is based on the
soil types, crops to be grown, and method of application for
your particular operation. The waste must be land applied at a
specified rate to prevent pollution of surface and/or ground
water. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops
where the waste is to be applied. This waste utilization plan
uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle and annual soil tests
are encouraged so that all plant nutrients can be balanced for
realistic yields of the crop to be grown.
Several factors are important in implementing your waste
utilization plan in order to maximize the fertilizer value of
the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the
needs of the crop to be grown and the nutrient content of the
waste. Do not apply more nitrogen than the crop can utilize.
Soil types are important as they have different infiltration
rates and leaching potential. Waste shall not be applied to
land eroding at greater than 5 tons per acre per year. Do not
apply waste on saturated soils or on land when the surface is
frozen. Either of these conditions may result in runoff to
surface waters. Wind conditions should also be considered to
avoid drift and downwind odor problems. To maximize the value
of nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or
not more than 30 days prior to planting. Soil incorporation
of waste will conserve nutrients and reduce odor problems.

r
Page 2
The acres needed to apply the animal waste is based on typical
nutrient content for this type of facility. Annual acreage
requirements may be more or less based on the waste analysis
report for your waste management facility.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract
No.
4069
40 9
4069
4069
4069
4069
4069
4069
4069
Field
Soil
Crop
Yield
Lbs. N
Acres
Lbs. N
Month to
No.
Type
Code
/Acre
/Unit
Used
Apply
4
NORF.
L
N/A
50.00
7.5
375
S-APRIL
4
NORF.
D
110
1.25
7.5
1031.2
MAR-JULY
3
NORF.
L
N/A
50.00
9.1
455
S-APRIL
3
NORF.
D
110
1.25
9.1
1251.2
MAR-JULY
2
RAINS
L
N/A
50.00
3.4
170
S-APRIL
2
RAINS
C
4.5
50.00
3.4
765
MAR-OCT
2
NORF.
L
N/A
50.00
4.0
200
S-APRIL
2
NORF.
C
6.1
50.00
4.0
1220
MAR-OCT
1
NORF.
C
6.1
50.00
6.2
1891
MAR-OCT
Total
54.2
7359
Available
Nitrogen
(includes commercial)
1705
Surplus Or
Deficit
-5654
Crop codes: Crop -unit
A=Barley-bu.
B=Bermudagrass(graze)-tons
C=Bermudagrass(hay)-tans
D=Corn(grain)-bu.
E=Corn(silage)-tons
F=Cotton-lbs. lint
G=Fescue(graze)-tons
H=Fescue(hay)-tans
I=Oats-bu.
J=Rye-bu .
K=Small grain(graze)-acre
L--Small grain(hay)-acre
M=Sorghum(grain)-cwt.
W=Wheat-bu.
Y=Fescue(pasture)-tons
Z=Sermudagrass(pasture)-tons

If more commercial fertilizer is used than shown in this plan,
then additional acres of land may be needed. A three to fifteen
feet wide permanent grass filter strip should be seeded along all
ditches in fields that receive animal waste.
Additional comments:
--------------------
it-��s
PL�iry i�n 1�
ALLauls
F-0 rA L-
BE(2MU1)A
14ik' L.r1gD
Sal
f71 EL73
Ca kA
0- CPA i to CR o P5
=m F i Ec.Ds
3 4---
Prepared by: W011,6 ,CD L- 11-65aq Title: I%jor an te: 1 .zq VB
Concurred in by: Date: L }
Producer
I understand that I must own or have access to equipment,
primarily irrigation equipment, to land apply the animal waste
described in this waste utilization plan. This equipment must be
available at the appropriate pumping time such that no discharge
occurs from the lagoon in a 25-year 1-day storm event. I also
certify that the waste will be applied on the land according to
this plan at the appropriate times and at rates that no runoff
occurs.
Date:
Producer
Technical Specialist: - - -_ Date: / V9-9
(Copy to producer and copy to case file)

If more commercial fertilizer is used than shown in this plan,
then additional acres of land may be needed. A three to fifteen
feet wide permanent grass filter strip should be seeded along all
ditches in fields that receive animal waste.
Additional comments:
--------------------
`rWS WOP 9A5 3EEIA UPDATED To MORE .AC-URA-rELY SHOW CROPS -Tb 8E UTILIZED.
`rim-s P[Am NAs scm E' Z)EGREE of Fi.Ex tNLr . FICLD =W I --Di, CoHSTAk'P`
FIE:t-D -44-- Z WILL BE oUeRSEt=DEED WI SG XF ReLbs -k 3 dQ �4 Aga Nc-r:
AL5o, Ckes 5cc" As 7z5kcro a(z Ci)7mhL MAC BE PtAK"M Sal REsDs 31 4-
BK ATEW'1�rm wEARs . A1=L� W iLL R r BF- IaSeb Fat WA5r� APPL1Cgriog r'Ve,KG -MA- '
Pr-RtOD. R EtD5 1 4 2.. ARE MORE `I-lAtA RbMQUATE FOR "N' Li 'T-ra' KE
Prepared by: 44j jASt1 L- +Am85cN ___ Title:YEtq.5P=-c, Date: I Z(8
Concurred in by: g Date: )-3/-9,p
Pro ucer
I understand that I must own or have access to equipment,
primarily irrigation equipment, to land apply the animal waste
described in this waste utilization plan. This equipment must be
available at the appropriate pumping time such that no discharge
occurs from the lagoon in a 25-year 1-day storm event. I also
certify that the waste will be applied on the land according to
this plan at the appropriate times and at rates that no runoff
occurs.
Date: /-.3/- ��
V�Ir.ducer
Technical Specialist: �, �J,-, Date: 11_E
(Copy to producer and copy to case file)

4F
ill
CARROLL'S FOODS, INC.
WARSAW, NC 28398
Project:
'EbDtF- -Towis� W Lip
Drawing:
s?Rpy FtrmLms
Location:
couwry
Engineer:
Owner:
F-fxbtic To"qSw4
Scale:
N c. �4 a—
Wrepared By: J+oWAPZ, 4CM50)'-A

I
RECEIVED
Nov 0 6 20LO
WATER QUALITY SECTION
Non-Discha-g2 Permitting
SWINE FARM
DESIGN, CONSTRUCTION, OPERATION,
AND MANAGEMENT PLAN
FOR
EDDIE JOHNSON
• 3552 Wean to Feeder
July 30, 1996
I certify that this flan has been prepared under my direct
supervision and meets the applicable regulations of
NRCS, DEM, and all other State and Local Regulations
to the best of my skmq_wled&,e and belief.
ea
M. Floyd ABA. iP.E. 7 Date
license No.';�2273•,

CARROLL'S FOODS, INC.
P. O. Drawer 856
WARSAW, NORTH CAROLINA 28398
FACILITY DESIGN AND
WASTE MANAGEMENT PLAN
Farm EDDIE JOHNSON
Name or Number
3552 WEAN TO FEEDER
Farm Description
Location
ROBESON COUNTY
Company Farm
Contract Grower X

SWINE FARM
DESIGN, CONSTRUCTION, OPERATION,
AND MANAGEMENT PLAN
EDDIE JOHNSON
3552 Wean to Feeder
TABLE OF CONTENTS
Lagoon Design Check List
Emergency Action Plan
Construction Information
Memorandum - Legal Requirements
Owner Contractor Information
Waste Management Facility Site Evaluation
Soil Investigation
Lagoon Design
Hazard Classification Data Sheet for Dams
Operation and Maintenance PIan
Construction Specifications for Lagoons
Seeding Specifications
Plan for Lagoon
Typical Cross -Section of Lagoon
Volume Calculations
Waste Utilization Plan with Attachment B
Maps
A_
Vicinity Map
B.
Topo Map
C.
Soils Map
D.
Flood Plain Map
E.
ASCS Map

0
CHECKED BY: M , �a r nT
? DATE:
LAGOON DESIGN CHECK LIST
I . Copy of 026 and maps if clearing involved.
2. Dam safety -
NJLN a. Dike over 15 feet to down stream slope and over 10 acre feet storage to top of
dike.
3. Adequacy of storage volumes -
✓ a. designed volume exceeds needs
b. all temporary storage stored above seasonal high watertable
C. include statement from landowner when he requests no sludge storage
_L d_ minimum 6 feet treatment volume depth
4. Operation & Maintenance Plan (sheet) -
a. begin and end pump -out elevations
/ 5. Location sketch -
✓ a. distances to nearest residence
✓ b. road numbers
C. north arrow
6.
Hazard Classification Sheet (NC-ENG-34) -
✓
a.
distance to nearest stream in event of dike failure
✓
b.
distance to nearest public road in event of failure
T /
C.
topo map showing lagoon location and information to support a&b
7.
Waste Utilization PIan
✓
a.
show all tracts & field numbers, field acreage, crops
b.
signatures of producer & person preparing plan
C.
agreement sheet signed by adjoining landowner if needed - showing tract
numbers, field numbers, acres, etc.
d.
ASCS maps of fields to be used for effluent disposal
e.
soil survey sheets showing all fields
f.
check suitability of soils for crops planned
_Z
g.
include attachment "B" on sampling procedure
8.
Soil Investigation Sheet (SCS-ENG-538)
a.
minimum of three borings on Class IV & V lagoons
b.
borings 2.0' below designed bottom of lagoon
C.
location & elevation of borings in relation to grid survey
d.
seasonal high water -table
9. Seeding specifications included (lagoon dike and other exposed areas around buildings)
-" I

_Iz
12.
I3,
14
15
16
✓ 17
✓ 18
Construction Specifications (sheet included)
a. need for cut-off trench addressed
b. need for sealing or lining with impervious material addressed and anticipated
Iocations of such area identified
C. protection of liner during initial filling and near flush pipes addressed
Grid Sheet (original or ledgable copy)
a. gridded area large enough to include embankment slopes and surface water
diversions
b. location & dimensions of lagoon & buildings shown (lagoon inside top
measurements shown and lagoon corners identified by grid stations)
C. surface water removal (pipes, outlets, etc) shown
d. soil borings location show
C. TBM location & elevation shown
f. existing utilities located (if applicable)
Typical cross-section included
a. dike elevation & top width shown
b. lagoon bottom elevation shown
C. side slopes shown
d. effluent outlet pipe invert elevation shown
C. building pads - elevation & grade shown
f. cut-off trench shown - if required
g. liner shown - if required
Volume Computations
a. excavation
b. dike fill CaSc��aiagee,-
c. pad fill
Summary Sheet
a. design requirements —
b. excavation volume
C. fill volumes
d. cut -fill ratio Val�,•..r C�1�41a{ta.s
C. job class
Location of subsurface drainage (if present)
Presence of utilities addressed
Observation of cultural resources statement included
Operation is outside of jurisdictional limits of municipalities
2

A ITTONS
mi
■
a
EMERGENCY ACTION PLAN
1. CALL THE DIVISION OF ENVIRONMENTAL MANAGEMENT (DEl•',)
NAME OF OFFICE��gµ ri� — klA Qc�Ac.ct�( ors
PHONE NUMBER Qro 44SG
2. CALL 911 IF THERE IS DANGER TO DOWNSTREAM PROPERTY
3. CONTACT CONTRACTOR IF NEEDED TO REPAIR PROBLEM
NAME
PHONE NUMBER
4. CONTACT THE CERTIFYING TECHNICAL SPECIALIST
NAME A-194aAOD L 40850wl
PHONE NUMBER 410 V9 3 - 343 4(w)

CARROLL'S FOODS, INC.
P. O. Drawer 856
WARSAW, NORTH CAROLINA 28398
IMPORTANT INFORMATION
ABOUT LAGOON CONSTRUCTION
LISTED BELOW IS A BRIEF SUMMARY OF VOLUMES AND OTHER
DATA: (SEE CONTENTS OF PLAN FOR MORE INFORMATION)
EXCAVATION
7220---
cubic
yards
FILL (pad & dike)
7220---
cubic
yards
TOP SOIL (minimum 3" thick)
250---
cubic
yards
CLAY LINER (represents a complete liner) 2476--- cubic yards
Constructed top of dam must include a minimum of 5% settlement -
EXAKPLE: 10 feet high dam will require 5% of 10 feet or 0.5 feet
fill above planned top of dam.
Clay content, thickness and compaction of liners (if required) are
very important. if the certifying technical specialist is unable
to approve the liner with normal field techniques, an independent
engineering analysis will be required,,, (see CONSTRUCTION
SPECIFICATIONS for additional information). If an independent
engineering analysis is required, this expense will be the
responsibility of the owner/grower.
Special attention needs to be given to the seeding specifications.
The lagoon dike must be seeded according to specifications before
the system can be certified and stocked with animals. (Consult
with your NRCS Conservationist regarding mulching)

U
MEMORANDUM
TO: All Prospective Contract Growers
FROM: Don Butler, Real Estate Manager
Howard Hobson, Resource Conservationist
RE: Legal requirements for swine growers in
North Carolina and how they relate to you
The facility design and waste management plan attached is. of the utmost importance to
you -and .to Carroll's. This plan must be approved by a designated technical specialist
or Professional Engineer prior to construction start. The lagoon must be constructed
exactly as designed unless changes are approved by the original designer. The approved
plan needs to become a part of your permanent records and must be readily available
for review if and when your farm is inspected by state regulatory personnel.
When earthwork and lagoon construction is complete and the top of the dike and
outside slopes of the lagoon have been graded, seeded, and fertilized it must pass a final
inspection by a designated technical specialist in order for your farm to be certified ready
to stock animals. At the time of final construction approval, the owner and the person
certifying design, construction, and irrigation plans must sign a document called
"Animal Waste Management Plan Certification". This document must be sent to the
Department of Environmental Health and Natural Resources in Raleigh. Copies of the
signed document should be kept in your permanent file, one copy goes to your local Soil
i and Water Conservation District office for their file, and a copy must be presented to
Carroll's Foods before any animals can be placed on your farm. The owner is
responsible for the Certification being completed and sent to the appropriate places.
Remember, NO CERTIFICATION -- NO ANIMALS.
I€ you have any questions about the above information, please contact one of
us by calling 910-293-3434, extension 246.

ATTENTION OWNER AND EARTH MOVING CONTRACTOR
PLEASE READ THIS BEFORE REVIEWING THE ATTACHED WASTE
MANAGEMENT PLAN.
This design has been prepared in accordance with USDA- Natural Resources Conservation
Service standards and properly installed, will allow certification and stocking of animals_
The following items should be discussed PRIOR to entering into a contract:
1. This design is in compliance with state and federal laws. Any changes in design may
result in non-compliance and failure to be eligible for certification. No animals can
be stocked until the lagoon construction is approved and certified to the Division of
Environmental Management (DEM). If a Dam Safety Permit is also required by the
State, then no water or animal waste may be impounded in the lagoon until the
lagoon and .dike construction are approved by the North Carolina Department of
Environment, Health and Natural Resources, Division of Land Resources (DLR).
2. This design has taken into account data including soils, topography, wetlands,
streams, dwellings, wind direction, and owners concerns.
3. The volume shown represents excavation and fill in the lagoon and pad area. It does
NOT account for cut/fill for liners, roads, borrow areas, drainage or other related
construction activities unless specifically covered in the design.
4. Typically, the excavation volume represents the bulk of earthwork and is used for
price negotiations. All earth work beyond this amount will be worked out between
the owner and contractor, CARROLL'S DOES NOT NEGOTIATE PRICES FOR
GROWERS.
5. It is the desire of Carroll's Foods that the contractor receives a fair price for earth
work and the land owner receives a properly constructed lagoon and pad that will
meet design requirements.
G. DO NOT MAKE ANY CHANGES TO THE DESIGN OR FARM LAYOUT
UNLESS THE ORIGINAL DESIGNER IS CONSULTED AND APPROVES.
CARROLL'S FOODS ASSUMES NO RESPONSIBILITY FOR ANY DEVIATION
FROM ORIGINAL DESIGN OR CHANGES MADE ON THE SITE BY
CONTRACTOR OR ANYONE OTHER THAN CARROLVS PERSONNEL.

f
_ United States
Department of
Agriculture
I
A
N
0
I
Natural
Resources
Conservation
Service
WASTE MANAGEMENT )FACILITY SITE EVALUATION
GENERAL INFORMATION
NAME EQr7ir- 7--,r, 1n
t
TELEPHONE 4'a _ 2- -
LOCATION t
1, 1k�
SIZE OPERATION 3557 trJl a� � Fc r,>r-R
NC-CPA-1 7
REV. 1, 2-96
LOCATION DATA
DISTANCE FROM NEAREST RESIDENCE NOT OWNED BY PRODUCER ;' _ FT.
DISTANCE FROM NEAREST PUBLIC FACILITY (school, church, eFc.) > 2 'oc) FT.
/
IS SITE WITHIN 100-YEAR FLOOD PLAIN?
YES NO ✓
If yes, NRCS cannot provide assistance.
IS SITE AT LEAST 100 FT_ FROM A "BLUE LINE" PERENNIAL STREAM?
YES NO
If no, site must be relocated.
IS SITE WTIIBN I MILE ZONING JURISDICTION OF A MUNICIPALTIY?
YES NO
If yes, landowner should consult with local zoning board about required
permits. Permits must be obtained prior to design approval.
ARE 17Tn.3 M IN CONSTRUCTION AREA?
YES NO
Iryes, see Part 503 or the National Engineering Manual and follow policy.
(Copies of maps or other reference materials may be attached to site
evaluations
NDS
WIII. SITE INVOLVE CLEARING WOODLAND OR ANY NON -CROPLAND? YES NO
If yes, producer must complete Form NRCS-CPA-38 (Request for Certified
Wetland Determination/Delineation).
WILL ACTION RESULT IN SWAMPBUSTING? YES _ NO
IF WETLANDS ARE INVOLVED, IT IS THE RESPONSIBILITY OF THE PRODUCER TO CONTACT THE US AR.UY CORP OF
ENGWEERS AND THE DIVISION OF ENVIRONMENTAL MANAGEMENT TO DErER6ilNE IF PERMITS ARE REQUIRED.
IF WETLANDS ARE INVOLVED, THE PRODUCER SHOULD NOT CLEAR ANY LAND UNTIL A WETLAND DELINEATION
IS MADE.
MRCS will provide technical assistance in wetlands only under the following conditions. For natural wetland
inclusions Iess than one acre in size, NRCS will provide assistance only if the functions and values lost are fully
mitigated For natural wetlands greater than one acre in size, NRCS will provide assistance only after a
rigorous sequencing process to include avoidance, minimization of impacts, and compensatory mitigation is
carried out in that order of preference.
ODOR CONTROL
HAS ODOR CONTROL BEEN DISCUSSED WITH PRODUCER.: /
• PREDOMINANT WIND DIRECTION? � YES ✓ NO
• PRECHARGING LAGOON WITH FRESH WATER TO AT LEAST 1/2 YES NO
OF THE CAPACITY?
• USING GOOD SOUND JUDGMENT IN LAND APPLICATION YES NO
OF WASTE? _

NC-CPA-17
REV. 1, 2-96
Page 2
OTHER ENVIRONMENTAL FACTORS
IS ENDANGERED AND/OR THREATENED SPECIES HABITAT PRESENT?
YES _ NO ✓
IS A DESIGNATED NATURAL SCENIC AREA INCLUDED IN THE PLANNING AREA OR
/
WILL PLANNED ACTIONS IMPACT ON AN ADJACENT NATURAL SCENIC AREA?
YES NO ✓
IS AN ARCHAF-OLOGIC.4L OR HISTORICAL SITE LOCATED IN THE PLANNED AREA?
YES NO
/
ARE THERE PRIME, UNIQUE, STATE OR LOCALLY IMPORTANT FARMLANDS IN THE
YES ✓ NO
OPERATING UNIT?
WILL THE ACTION RESULT Rai S ODBUSTING?
YES _ NO _✓
If the answer to any of the above is yes, NRCS will not pro,,ide technical
assistance unless a�enc -policy is followed.
WASTE NtAiNAGENJENT - -
DOES PRODUCER 0%VN ENOUGH LAND TO PROPERLY LAND APPLY ALL Il ISTE YES ✓ NO
IN"CLUDING SLUDGE, ALTHOUGH SLUDGE MAY ONLYBE APPLIED INFREQUEN-FLY? � ~
IF NO. DOES PRODUCER HAVE ACCESS TO MORE L4ND? YES NO
IF LAND IS NOT OWNED BY PRODUCER, CAN PRODUCER GET AGREEMENT ON "ND YES NO
ON WHICH TO APPLY WASTE?
(Attach Waste Utilization Plan to site evaluation.)
SOIL INVESTIGATION - VALID ONLY IF SOIL INVESTIGATION
SHEET ATTACHED /
IS SOIL, SUITABLE FOR LAGOON? YES _ NO ✓
IS A LINER REQUIRED? YES NO
TYPE OF LINER TO BE USED_ CLAY ✓BENTONITE SYNTHETIC
IF CLAY LINER IS TO BE USED, IS SUITABLE CLAY AVAILABLE ON YES NO
SITE?
I
IF CLAY IS NOT AVAILABLE ON SITE, DOES LANDOWNER HAVE YES NO
ACCESS TO CLAY? �/
IS A CORE TRENCH REQUIRED7 YES _ NO ✓ (use
(Attach soil investigation sheet to site evaluation.)
IS SUBSURFACE DRAIN TILE PRESENT? YES _ NO
(If yes, tile must be removed or plugged)
SITE APPROVED
COMMENTS
YES NO
THIS SITE INVESTIGATION IS VALID FOR TWELVEMONTHS FROM THE DATE SHOWN BELOW. IF CONSTRUCTION
HAS NOT BEEN STARTED WITHIN TWELVE MONTHS, A NEW SITE R"ESTIGATION WILL BE REQUIRED. I'
SIGNATURE
DATE 9,9
V Changes in the local or state law or changes in the standard could require a nesv site investigation.

SCS-ENG-SU U. S. DEPARTMENT OF AGRICULTURE
Re- 5-70 SOIL CONSERVATION SERVICE
SOIL INVESTIGATION TO DETERMINE SUITABILITY OF PROPOSED POND SITE
FARMER'S NAME DISTRICT
DATE (�1 LO6 COUNTY-- FRoitF5tiitL _
S. C. S. PHOTO SHEEP NO. WORK UNIT
WATERSHED AREA MEASUREMENTS
CROPLAND ACRFS PASTURE ACRES
WOODLAND ACRES TOTAL ACRES POND CLASS WORK UNIT CONSERVATIONIST
SKETCH OF PROPOSED POND SHOWING WHERE BORINGS WERE MADE (Approz scale I"= feet)
Locale referrncr point in crnter line of dam and Identify on skrtcA.
■■■■■■r■r■■r
M■■
—
■
ISO
MINE
■
ONCE■
■
■■■r■■■
L■■
sol
M.00=
Isclow
Rim
■■r■■■■rr1■r■■■■■■r■EMENOM■■
■■�■■r■E�:'
■i■■■■■■r�r■��!�t�■■
■■■■■®■�■■�e■■r■r■■r■■r�■■■■
■■N
I■■
'r■■■■■LCr■■■r■E■■■■
■■E■■■■�■■■■■■�■■■!■■!�■■■■
■■I■■■■®■r■■■■E■■■RI■■U■■■■
��r�!■!■�■�.r�!
I■;■i��■�■�■.r��r�■r;m«■art■!■
®,EMINufflu
lrl1MMi`rM■1■1■1
EMMIrl■I■IN
+!�`�E-
IRS
�''�r'�.■I■�'■i■l©i■■I■1d�lrlr'®lair!■dam
■'■!■'■i
!�
�i
■!■f
r "
!'
i'
I�:'�1■!�
�l�i'�.
i"I
IN
l
M■S■R
100'101rl®!�3�1�
�;r1■
1'�l�!■lrl�
�'f�i■�■?■!���1■■�■�Il�lr'■lam;■lr!■'®I�'■I■I�
MUM:
■��■`���rlJOURI'
MIN'■i�?rIEURRIN01■lam
L9
�■
■;■ice'■
MOW
MIMIM
■i
I■INAIRE■°I!ImI�
�
IBORINGS MADE BY RAC 4iQ E— _ SIGNATURE & 1-1-1 E- s LM7— ,tqE• I

'
TYPES OF MATERIAL ENCOUNTERED IN BORINGS
(Use one of systems below)
UNIFIED CLASSIFICATION USDA CLASSIFICATION
GW-Well graded gravels; gravel, sand mix g- gravel
GP -Poorly graded gravels s - sand
GM - Silty gravels; gravel -sand -silt mix vfs-very fine sand
GC - Clayey gravels; gravel -sand -clay mix sl-sandy loam
SW -Well graded sands; sand -gravel mix fs] -fine sandy loam
Sp -poorly graded sands 1- loam
SM -Silty sand gl - gravelly loam
SC -Clayey sands; sand -clay mixtures si-silt
ML-Silts; silty, v. fine sands; sandy or clayey silt sil -silt loam
CL-Clays of low to medium plasticity cl-clay loam
CH -Inorganic clays of high plasticity sicl-silty clay loam
loam
MH - Elastic silts scl -sandy clay
OL - Organic silts and silty clays, low plasticity sic -silty clay
OH -Organic clays, medium to high plasticity c-clay
I_ Suitable material for erzbankment :s available EfYee D No llndir fe where !pealed an !ha skerc4 on
,.L.rst tide)
REMARKS:
=2, KEL7 ❑rj
MACE S0.L 15 AdAJ L A$L� oN SITE.
'
2. Ezplsin bards requiring special attention in design (5ecocae. sprine.-rocA etc!
GENERAL REMARKS:
24
25
26
27
128
29
30
31
32
J 33
34
35
36
37
38
39
40
41
42
43 1
44
45
46
471
48
49
50
51
F1
Ti-,
Hi
I
1
11
1
`1
I

0 LAGOON DESIGN
1-4
0,3perator:EDDIE JOHNSON County: ROBESON Date_ 07/03/96
Distance to nearest residence (other than owner): 2640.0 feet
�1.
AVERAGE LIVE WEIGHT (ALW)
0 sows (farrow to finish) x 1417 lbs. =
0 lbs
0 sows (farrow to feeder) x 522 lbs.
0 head (finishing only) x 135 lbs.
0 lbs
0 lbs
0 sows ( farrow to wean) x 433 lbs.
0 lbs
3552 head (wean to feeder) x 30 lbs. =
106560 lbs
Describe other :
0
Total Average Live Weig t =
106560 lbs
�2.
MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 106560 lbs. ALW x Treatment Volume(CF)/lb. ALW
Treatment Volume(CF)/lb. ALW = 1 CF/lb. ALW
Volume = 106560 cubic feet
3.
STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 26640.0 cubic feet
4.
TOTAL DESIGNED VOLUME
Inside top length (feet)-------------------- 340.0
Inside top width (feet)---------------------- 110.0
Top of dike elevation (feet)----------------- 55.4
Bottom of lagoon elevation 42.9
-(feet)------------
Freeboard (feet)- 1.0
Side slopes (inside lagoon)------------------- 3.0
1
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH
DEPTH
3.0 3.0 3.0 3.0 334.0 104.0
11.5
AREA OF TOP
LENGTH * WIDTH =
334.0 104.0 34736 (AREA OF TOP)
AREA OF BOTTOM
LENGTH * WIDTH =
265.0 35.0 9275 (AREA OF BOTTOM)
AREA OF MIDSECTION
LENGTH * WIDTH * 4
299.5 69.5 83261 (AREA OF MIDSECTION
* 4)
CU. FT. = AAREA TOP + (4*AREA MIDSECTION) + AREA BOTTOMO
* DEPTH/6
34736.0 83261.0 9275.0
1.9
Total Designed Volume Available =
243938 CU. FT.

a
I.. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
340.0 110.0 37400.0 square feet
IBuildings (roof and lot water)
0.0 square feet
Describe this area.
TOTAL DA 37400.0 square feet
Design temporary storage period to be
180 days.
_A.
Volume of waste produced
Feces & :urine production in gal./day per
135 lb. ALW 1.37
Volume = 106560 lbs. ALW/135 lbs. ALW *
1.37 gal/day 180 days
Volume = 194650 gals. or 26022.7 cubic
feet
B.
Volume of wash water
This is the amount of fresh water used for
washing floors or volume
of fresh water used for a flush system.
Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume 710.0 gallons/day *
180 days storage/7.48 gallons
per CF
Volume 17085.6 cubic feet
`
C.
Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds
evaporation by largest amount.
180 days excess rainfall =
7.0 inches
Volume = 7.0 in * DA / 12 inches per
foot
Volume = 21816.7 cubic feet
■
4

I
5D. Volume of 25 year - 24 hour storm
1 Volume = 14.0 inches / 12 inches per foot * DA
Volume = 43633.3 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A.
26023
cubic
feet
5B.
17086
cubic
feet
5C.
21817
cubic
feet
5D.
43633
cubic
feet
TOTAL 108558 cubic feet
SUMMARY
�.
Temporary storage period==============_ ====>
180
days
Rainfall in excess of evaporation===-=======>
7.0
inches
25 year - 24. hour :rainfall________________=>
14.0
inches
'
Freeboard==========—=======_==============>
1.0
feet
Side slopes======_==_= ____=__-__—___-_= _>
3.0
: 1
Inside top length=====__================= >
340.0
feet
Inside top width=====___________ __________>
110.0
feet
Top of dike elevation==================== -->
55.4
feet
Bottom of lagoon elevation=====_ ---- = _====>
42.9
feet
Total required volume=========_ ============>
241758
cu. ft.
Actual design volume=====_====____=_= =>
243938
cu. ft.
Seasonal high watertable elevation (SHWT)===>
47.7
feet
Stop pumping elev._______________________—>
50.7
feet
Must be > or = to the SHWT elev.==========>
47.7
feet
Must be > or = to min. req. treatment el.=>
48.9
feet
Required minimum treatment volume=========>
133200
cu. ft.
Volume at stop pumping elevation=====_=====>
133562
cu. ft.
Start pumping elev.--=__---____=-_ ___=__=_=>
53.0
feet
Must be at bottom of freeboard & 25 yr. rainfall
Actual volume less 25 yr.- 24 hr. rainfall=>
200305
cu. ft.
Volume at start pumping elevation====-
199097
cu. ft.
===-=>
Required volume to be pumped===============>
64925
cu. ft.
Actual volume planned to be pumped=- —>
65535
cu. ft.
Min, thickness of soil liner when required=>
1.8
feet
DESIGNED BY: APPROVED BY:
l:4,eAWs
.- DATE : 7i3a/9�
DATE: 7,�'6
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
• r �
*

�5D.
F
Volume of 25 year - 24 hour storm
Volume = 14.0 inches / 12 inches per foot
* DA
Volume = 49439.4 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 26023 cubic feet
5B. 17086 cubic feet
5C. 24720 cubic feet
5D. 49439 cubic feet
TOTAL 117267 cubic feet
6.
SUMMARY
Temporary storage period====================>
180
days
Rainfall in excess of evaporation===========>
7.0
inches
25 year - 24 hour rainfall===_=_______-__=_->
14.0
1.0
inches
feet
Side slopes=====_______ _______-= =_--_____>
3.0
: 1
Inside top length========= ============_ ==>
350.8
feet
Inside top width= __==__=_=________________>
120.8
feet
Top of dike elevation====-=__-______=_ —====>
55.4
feet
Bottom of lagoon elevation== ==========-=___=>
41.1
feet
Total required volume.===============_ ==_ ==>
250467
cu. ft.
Actual design volume== --------- _____________>
310790
cu. ft.
'
Seasonal high watertable elevation (SHWT)===>
47.7
feet
Stop pumping elev.===-___-__=_-__________=>
50.7
feet
Must be > or = to the SHWT elev.==========>
47.7
feet
Must be > or = to min. req. treatment el.=>
47.1
feet
Required minimum treatment volume===========>
133200
cu. ft.
Volume at stop pumping elevation============>
183498
cu. ft.
Start pumping elev. = ____=== ___=--___>
53.0
feet
Must be at bottom of freeboard & 25 yr. rainfall
Actual volume less 25 yr.- 24 hr. rainfall =>
261351
cu. ft.
Volume at start pumping elevation==-==__ =__>
259477
cu. ft.
Required volume to be pumped=== ------- =====>
67828
cu. ft.
Actual volume planned to be pumped= —== -_==>
75979
cu. ft.
Min. thickness of soil liner when required==>
2 -meet MIA
DESIGNED BY : Q d. 49W-81- APPROVED BY:
C- A gAMLt
DATE: 7/31 q ` DATE:
NOTE: SEE! ATTACHED WASTE UTILIZATION PLAN
COMMENTS: �[ 1" Tb p ,�,L n E�7'iM�_(�" "rappscwL)
E6g
ie Abl E
ua- t�+y3e�► �Rw(.'
w j Lt N r -- a VaAznr. .3ta, -tea
,?As�.93 8
5cm .Z5)
�
r30'
`
�7
`
= ISO
�Z
� _ 2A7G &►'i�.
z-r

1
1
I
HAZARD CLASSIFICATION DATA SHEET FOR DAMS
Landowner Eddie Johnson County Robeson
Estimated Depth of Water to Top of Dam 4 Ft. Length of Flood Pool 300 Ft.
Date of Field Hazard Investigation 6/17/96
Evaluation by reach of flood plain downstream to the point of estimated minor effect from sudden
dam failure.
Est. Elev.
Est, Elev.
Kind of ;Improvements:
of Breach
Reach
' Length Width Slope :Land Use
Improvements
Above
Floodwater Above
Flood Plain
Flood Plain
Ft. Ft. % Farmland :
None
f 7'
NIA
1
300 75 < 1 %
2
3
'
Describe potential for loss of life and damage to existing or probable future downstream improvements
for a sudden breach. A sudden failure of the structure will not endanger life nor cause significant
dams a to buildings, agricultural land, or public roadways. The structure is approximately 1,200 feet_
from Ashpole Swamp and approximately 2.5 miles to NC 41 along the flow of the swamp.
Hazard Classification of Dam (A, B, C) (see NEM-Part 520.21) A
NRCS Dam. Classification (I, II, III, IV, V) It
By L I Date 7130/96
M. Flvyd Adams J .E.
'J 1

SHEET 1 OF 2
OPERATION AND MAINTENANCE PLAN
-' -
This lagoon is designed for waste treatment (permanent storage) and
iso days of temporary storage. The time required for the planned
fluid level (permanent and temporary storage) to be reached may vary
due to site conditions, weather, flushing operations, and the amount
of fresh water added to the system.
The designed temporary storage consists of 180 days storage for:
(1) waste from animals and (2) excess rainfall after evaporation. Also
included is storage for the 25 year - 24 hour storm for the location.
The volume of waste generated from a given number of animals will be
fairly constant throughout the year and from year to year, but excess
rainfall will vary from year to year. The 25 year rainfall will not
be a factor to consider in an annual pumping cycle, but this storage
volume must always be available.
A maximum elevation is determined in each design to begin
pumping and this is usually the outlet invert of pipe(s) from
building(s). If the outlet -pipe is not installed at the elevation to
begin pumping, a permanent marker must be installed at this elevation
to indicate when pumping should begin. An elevation must be established
to stop pumping to maintain lagoon treatment depth.
Pumping can be -started or stopped at any time between these two
elevations ,for operating convenience as site conditions permit, such as
weather, soils, crop, and equipment in order to apply waste without
runoff or leaching.
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent damage to crops.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre --
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times. When precharging is complete,
flush buildings with recycled lagoon liquid. Fresh water should not
be used for flushing after initial filling.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see attachment)
before land application.
3. Begin temporary storage pump -out of the lagoon when fluid level
reaches the elevation 53.0 as marked by permanent marker. Stop pump -
out when the fluid level reaches elevation 50.7 . This temporary
storage, less 25 yr- 24 hr storm, contains 64925 cubic feet or
485638 gallons.

SHEET 2 OF 2
4. The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended maximum application rate is 0.3
inch per hour. Refer to the waste utilization plan for further details.
5. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
' 7. All surface runoff is to be diverted from the lagoon to stable
outlets.
S. Keep a minimum of 25 feet of grass vegetated buffer around
waste utilization fields adjacent to perennial streams. Waste will
not be applied in open ditches. Do not pump within 200 feet of a
' residence or within 100 feet of a well. Waste shall be applied in a
manner not to reach other property and public right-of-ways.
9. The Clean Water Act of 1977 prohibits the discharge of
' pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.

SHEET 1 OF 2
SPECIFICATIONS FOR CONSTRUCTION OF WASTE TREATMENT LAGOONS
FOUNDATION PREPARATION:
The foundation area of the lagoon embankment and building pad shall be
cleared of trees, logs, stumps, roots, brush, boulders,sod and rubbish.
Satisfactory disposition will be made of all debris. The topsoil from
the lagoon and pad area should be stripped and stockpiled for use on
the dike and pad areas. After stripping, the foundation area of the
lagoon embankment and building pad shall be thoroughly loosened prior
to placing the first lift of fill material to get a good bond.
EXCAVATION YAND -EARTHFILL`PLACEMENT:
The completed excavation and earthfill shall conform to the lines,
grades, and elevations shown on the plans. Earthfill material shall
be free of material such as sod, roots, frozen soil, stones over
6.inches in diameter, and other objectionable material. To the extent
they are suitable, excavated materials can be used as fill. The fill
shall be brought up in approximately horizontal layers not to exceed 9
inches in thickness when loose and prior to compaction. Each layer
will be compacted by complete coverage -with the hauling and spreading
equipment or standard tamping roller or other equivalent method.
Compaction will be considered adequate when fill material is observed
to consolidate to the point that settlement is not readily detectible.
NOTE THE SPECIAL REQUIREMENTS FOR PLACEMENT OF LINERS IN THE LINER
SECTION OF THIS SPECIFICATION. The embankment of the lagoon shall be
installed using the more impervious materials from the required
excavations. Construction of fill heights shall include 5 percent for
settlement. Dikes over 15 feet in height and with an impoundment
capacity of 10 acre-feet or more fall under the jurisdiction of the NC
Dam Safety Law. The height is defined as the difference in elevation
from the constructed height to the downstream toe of the dike.
Precautions shall be taken during construction to prevent excessive
erosion and sedimentation.
LINER_ THE -MINIMUM
_REQUIRED -THICKNESS -SHALL -BE---1.8-ft.
NOTE: LINERS (PARTIAL OR FULL) ARE REQUIRED WHEN THE -ATTACHED SOILS
INVESTIGATION REPORT SO INDICATES OR WHEN UNSUITABLE MATERIAL IS
ENCOUNTERED DURING CONSTRUCTION. A TYPICAL CROSS SECTION OF THE LINER
IS INCLUDED IN THE DESIGN WHEN LINERS ARE REQUIRED BY THE SOILS REPORT.
When areas of unsuitable material are encountered, they will be over -
excavated below finish grade to the specified depth as measured
perpendicular to the finish grade. The foundation shall be backfilled
as specified to grade with a SCS approved material (ie - CL,SC,CH).
REFER TO THE SOILS INVESTIGATION INFORMATION IN THE PLANS FOR SPECIAL
CONSIDERATIONS.

u
SHEET 2 OF 2
Soil liner material shall come from an approved borrow area. The
minimum water content of the liner material shall be optimum moisture
content which relates to that moisture content when the soil is kneaded
in the hand it will form a ball which does not readily separate. Water
shall be added to borrow as necessary to insure proper moisture content
during placement of the liner. The moisture content of the liner
material shall not be less than optimum water content during placement.
The maximum water content relates to the soil material being too wet
for efficient use of hauling equipment and proper compaction. Proper
compaction of the liner includes placement in 9 inch lifts and
compacted to at least 90 percent of the maximum ASTM D698 Dry Unit
Weight of the liner material. When smooth or hard, the previous lift
shall be scarified and moistened as needed before placement of the next
lift.
The single most important factor affecting the overall compacted perme-
ability of a clay liner, other than the type of clay used for the
liner, is the efficient construction processing of the compacted liner.
The sequence of equipment use and the routing of equipment in an estab-
lished pattern helps assure uniformity in the whole placement and
compaction process. For most clay soils, a tamping or sheepsfoot
roller is the preferable type of compaction equipment.
The soil liner shall be protected from the discharge of waste outlet
pipes. This -can be done by using some type of energy dissipator(rocks)
or using flexible outlets on waste pipes.
Alternatives to soil liners are synthetic liners and bentonite sealant.
When these are specified, additional construction specifications are
included with this Construction Specification.
CUTOFF TRENCH:
--------------
A cutoff trench shall be constructed under the embankment area when
shown on a typical cross section in the plans. The final depth of the
cutoff trench shall be determined by observation of the foundation
materials.
VEGETATION_
All exposed embankment and other bare constructed areas shall be seeded
to the planned type of vegetation as soon as possible after construc-
tion according to the seeding specifications. Topsoil should be placed
on areas of the dike and pad to be seeded. Temporary seeding or mulch
shall be used if the recommended permanent vegetation is out of season
dates for seeding. Permanent vegetation should be established as soon
as possible during the next period of approved seeding dates.
REMOVAL OFEXISTINGTILEDRAINS
-- - -
When tile drains are encountered, the tile will be removed to a minimum
of 10 feet beyond the outside toe of slope of the dike. The tile
trench shall be backfilled and compacted with good material such as
SC, CL, or CH.
4

SEEDING SPECIFICATIONS
AREA TO BE SEEDED: 2.0 ACRES
USE THE SEED
MIXTURE INDICATED AS FOLLOWS:
0.0 LBS.
FESCUE GRASS AT 60 LBS./ACRE
(BEST SUITED ON CLAYEY OR WET SOIL CONDITIONS)
SEEDING DATES: SEPTEMBER 1 TO NOVEMBER 30
FEBRUARY 1 TO MARCH 30
0.0 LBS.
RYE GRAIN AT 30 LBS./ACRE (NURSERY FOR FESCUE)
0.0 LBS.
'PENSACOLA' BAHIA GRASS AT 60 LBS./ACRE
(SEE FOOTNOTE NO. 1)
SEEDING DATES: MARCH 15 TO JUNE'15
16.0 LBS.
HULLED COMMON BERMUDA GRASS AT 8 LBS./ACRE
(SUITED FOR MOST SOIL CONDITIONS)
SEEDING DATES: APRIL 1 TO JULY 31
0.0 LBS.
UNHULLED COMMON BERMUDA GRASS AT 10 LBS./ACRE
SEEDING DATES: JANUARY 1 TO MARCH 30
0.0 LBS. RYE GRASS AT 40 LBS./ACRE (TEMPORARY VEGETATION)
SEEDING DATES: DECEMBER 1 TO MARCH 30
LBS.
APPLY THE FOLLOWING:
2000.0 LBS. OF 10-10-10 FERTILIZER (1000 LBS./ACRE)
4.0 TONS OF DOLOMITIC LIME (2 TONS/ACRE)
200.0 BALES OF SMALL GRAIN STRAW (100 BALES/ACRE)
ALL SURFACE DRAINS SHOULD BE INSTALLED PRIOR TO SEEDING. SHAPE
ALL DISTURBED AREA IMMEDIATELY AFTER EARTH MOVING IS COMPLETED.
APPLY LIME AND FERTILIZER THEN DISK TO PREPARE A 3 TO 4 INCH
SMOOTH SEEDBED. APPLY SEED AND FIRM SEEDBED WITH A CULTIPACKER
OR SIMILAR EQUIPMENT. APPLY MULCH AND SECURE WITH A MULCH
ANCHORING TOOL OR NETTING.
1. PENSACOLA BAHIAGRASS IS SLOWER TO ESTABLISH THAN COMMON
BERMUDA GRASS. WHEN USING BAHIA, IT IS RECOMMENDED THAT 8
LBS./ACRE OF COMMON BERMUDA BE INCLUDED TO PROVIDE COVER
UNTIL BAHIAGRASS IS ESTABLISHED.
I
I

OS
-
_.
a
N a I �.I it � 7,1� I'I i i I
ry I I
N
�o2*a
V rye ;aSl j.. I o4
1
17
logo All;
LL
1 ff
i
N�� q �rvI
�'
pS
4 ,
.N
0
.
'�
iff n U-2 ff m u ff -le N a a w a U:u

Swine Confinement
Building
Finished Floor Elev.
bump
Top Pad Elev. 54.7
8" Pipe
Invert Elev.
0 72 ru A 0 a a X a ff AW
TYPICAL CROSS-SECTION
Single Stage Lagoon -Pit Recharge Design
RoeesoH County, NC
EDOIE 3owNsau •
Total Design Storage Elev. 54..4o
Invert Outlet Pipe Elev.
Stop Pump Elev. 50.7
Bottom Elev. ¢z, 9
©.za
Support post
atural `Ground; , .......Lp—
.:
I-S FT, - DESIGN MIN. CLAY LINERTHICKNESS
;; •;
areas of unsuitable material encountered during �nstruction' • � • . ..,:,,.
of lagoon slopes and bottom will be excavated below grade (for
the minimum clay liner thickness), backfilled (with approved soil .
material) & compacted (to clay liner construction specifications
In design), ...see soils Investigation +, ' ''
w.
.s ft.
Settled Top Dam Elev.
Add 5% Settlemc
Constructed Top C
Ki 2' I
-SS . 40
Core
Trench
Remove overburden material and
establish embankment/core on firm
soil material.... see soils investigation
R. Horton, MRCS (2/95)

M M = M M M M M M M a a 0 a M a R 0 a
Oriantatil
54.1
53.1
53.1
62.1
62.
61.
Lowsr Left
30 Mesh Surface
Existing
Project: EDDIE JOHNSON REVISION
Drawing: 3620 NURSERY WEAN -FEED
Number:
Location:
Bid bate:
Engineer:
Owner:
Estimator:
Prepared bW: using Sitawork
■tion: 20.8
30 Mesn 5urface

Ms now � � i � M i iMMOM M O MMO M W
30
0
weter
Plot of all data for the surface:
Existing
Project: EDDIE JOHNSON REVISION
Drawing: 3620 NURSERY WEAN -FEED
Number:
Location:
Bid Date:
Engineer:
Owner:
Estimator:
Prepared by: using Sitework

a am a a a a MA a a an X a a on a.
.0
3. 0
.5
Rimeter
Contour plot of
Existing
Project: EDDIE JOHNSON REVISION
Drawing: 3620 NURSERY WEAN -FEED
Number:
Location:
aid Date:
Engineer:
Owner:
Estimator:
Prepared bg: using Sitework

om pw_ P---=-
Orientation: -46.0 Z Me nir'
Z
Lower Left
30 Mush Surface
Balanced
Project: EDDIE JOHNSON REVISION
Drawing: 362e NURSERY WEAN -FEED
Number:
Location:
aid Date:
Engineer,.
Owner:
Estimator:
Prepared by: using Sitmwork
Inclination: 20.0
30 Mush Surface

JMll1Wii ' we' er'K't : 00''f 1t lain',
Iterating to balancing within 10.0 cubic yards...
delta Cut Flll
0.00 7220. 7220.61
0.00 7103.31 7588.00
0.00 7103.31 7588.00
-0.12 7246.40 7140.79
-0.10 F7220.61f
Lower "Proposed" by 0.10 feet.
Project: EDDIE JOHNSON REVISION
Drawing: 3520 NURSERY WEAN -FEED
Number:
Location:
Bid Date:
Engineer:
Owner:
Estimator:
Prepared by: using Sitework
CUT - FILL
0.00
-484.69
-484.69
105.61
0.00
-)K A0rF_: Tws �)cLv MC L7oEs NoT =NCLUcE AAy
OVeR o T - FoR LtikvR, ORAiN,oGE, lAarss
Ro,4,o5 , ffrc�
7/1 jq6

MIMMKIWOM19-
04
4.I
l
"4
4"64LW"64
.44�"@334.
e
4. 70
63.80
.68w,,4-e .................................................................
-W4M,ti ... A-& ............................................................
v4a
42W-29 ........
...............................................
...................... ................... 42/90
............................. ....... .... . '142.90
.............................................................
.............................................. ........ ........... St. 4 8
Plot of all data for the surface:
Balanced
Project: EDDIE JOHNSON REVISION
Drawing: 3520 NURSERY WEAN -FEED
Number:
Location:
Bid Onto:
Engineer:
Owner:
Estimator:
Prepared bU*. using Sitework

................................................................
Sfo•..¢a.. .................. ........................................ .........................................
330'
$o-TTGM r�.Lxl.
.......................................................................................................................................
35c
............................
a5.4o
erimeter
Plot of the contour data for the surface:
Balanced
Project: EDDIE JOHNSON REVISION
Drawing: 3620 NURSERY WEAN -FEED
Number:
Location:
Bid Date:
Engineer:
Owner:
Estimator:
Prepared by: using Sitework

20
Plot of the sloping lines for the surface:
Balanced
Project: EDDIE JOHNSON REVISION
Drawing: 3628 NURSERY WEAN-FEEO
Number:
Location:
Bid Date:
Engineer:
Owner:
Estimator:
Prepared bWt using Sitewark

manna an MIMMUM ME M & R A M,
rimeter
Contour plot of
Balanced
Pr0jmct: EDDIE JOHNSON REVISION
Drawing: 3520 NURSERY WEAN -FEED
Number:
Location:
Bid Data:
Engineer:
Owner:
Estimator:
Prepared bye: using Sitawork

54
oa. .64
55.�4 87C)4_
54, 70 164.20
;Z��54.70
64.79
;64.64
rjS • O Q~
154,70
:64.20 4-rl#-
Plot of all data for the surface:
Balanced
Project: EODIE JOHNSON REUISION
Crowing: 3529 NURSERY WEAN -FEED
Number:
Location:
Bid Data:
Engineer:
Ownsr:
Estimator:
Prepared bW: using Sitawark
54.70
54.64
ss. 0 4-
A
0
4.70
S4. 20 �-
4
64.70

164
63.80
.....................
61.90
.90
04
4.70
�iE os , ee ,53.20
...................... ............ ­­ ................................................................ I .......................
.. ......... .................. A
......................... .................... I., ................ .......................
m 'o90A
........................ .......... 4 2/9 0
........... ............ ........................ .........
2,
............... .... ................... .......... ......... ........
........... .46
If Aoter
: EDDIE JOHNSON REVISION: 3620 NURSERY WEAN -FEED: Bmlmncmd
01 JUL es e8:49 AM

a UK W-1
66.ee
66.ee
64.ee
52.80
Be.ee
48.ee
46.00
44.Oe
42.ee
(269.62,407.66)
<342.03)
(268.82,66.63)
: EDOIE JONNSON REVISION: 3620 NURSERY WEAN -FEED 01 JUL 96 08:49 AM

d
I
EL. 04
L4�64�W"4�4�fi
TO
54.70
63.80
...... ­ .......... ­­­ .......... - I ...... 1­.­ ...............
.....................................................................
'42.;.90 .....................................................................................
cggss - $-'g cr 16 m—
Se c K wrr Vac P.
......... . ..... I..' ........................ L .....
. 53.20
.............................
........................................ .,
'.5
.......................
.........................
....... 4 2\9 0
..........................
. . 56. 0
.............................................. 5 .40
: EDDIE JOHNSON REVISION:'3620 NURSERY WEAN -FEED: Balanced 01 JUL 96 08:60 AM

In Oman
SB. 00
ss.00
64.00
52.ee
50.00
48.09
1EP-MIll
44.00
42.00
(93.33,139.79)
EDDIE JOHNSON REVISION: 3520 NURSERY WEAN -FEED
(373.32)
w 0; 'm "a'
r
[466.55,139.62i
01 JUL 96 08:60 AM

11
WASTE UTILIZATIONPLAN
- -
owners name--:EDDIE JOHNSON County:ROBESON
Mail Address-:FAIRMONT
Type of production unit ---- :WEAN -FEED
Number of animal units-----: 3552
Type of waste facility ----- :Anaerobic Lagoon
Temporary storage period---: 180 days
Method of application ------ :IRRIGATION
Amount of animal waste produced------------------: 1500 tons/year
Amount of plant available N produced by animals-: 1705 lbs./year
Commercial N to apply on planned acreage--------: 0 lbs./year
Your animal waste utilization plan has been specifically
developed for your swine operation. The plan is based on the
soil types, crops to be grown, and method of application for
your particular operation. The waste must be land applied at a
specified rate to prevent pollution of surface and/or ground
water. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops
where the waste is to be applied. This waste utilization plan
uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle and annual soil tests
are encouraged so that all plant nutrients can be balanced for
realistic yields of the crop to be grown.
Several factors are important in implementing your waste
utilization plan in order to maximize the fertilizer value of
the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the
needs of the crop to be grown and the nutrient content of the
ry waste. Do not apply more nitrogen than the crop can utilize.
® Soil types are important as they have different infiltration
rates and leaching potential. Waste shall not be applied to
land eroding at greater than 5 tons per acre per year. Do not
apply waste on saturated soils or on land when the surface is
frozen. Either of these conditions may result in runoff to
surface waters. Wind conditions should also be considered to
avoid drift and downwind odor problems. To maximize the value
of nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or
not more than 30 days prior to planting. Soil incorporation
of waste will conserve nutrients and reduce odor problems.
I
I

WASTE UTILIZATION PLAN
----------------------
Owners name--:EDDIE JOHNSON County:ROBESON
Mail Address-:FAIRMONT
Type of production unit---- :WEAN -FEED
Number of animal units-----: 3552
Type of waste facility ----- :Anaerobic Lagoon
Temporary storage period ----: 180 days
Method of application ------ :IRRIGATION
Amount of animal waste produced--------------------: 1500 tons/year
Amount of plant available N produced by animals-: 1705 lbs./year
Commercial N to apply on planned acreage--------: o lbs./year
Your animal waste utilization plan has been specifically
developed for your swine operation. The plan is based on the
soil types, crops to be grown, and method of application for
your particular operation. The waste must be land applied at a
specified rate to prevent pollution of surface and/or ground
water. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops
where the waste is to be applied. This waste utilization plan
uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle and annual soil tests
are encouraged so that all plant nutrients can be balanced for
realistic yields of the crop to be grown.
Several factors are important in implementing your waste
utilization plan in order to maximize the fertilizer value of
the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the
needs of the crop to be grown and the nutrient content of the
waste. Do not apply more nitrogen than the crop can utilize.
Soil types are important as they have different infiltration
rates and leaching potential. Waste shall not be applied to
land eroding at greater than 5 tons per acre per year. Do not
apply waste on saturated soils or on land when the"surface is
frozen. Either of these conditions may result in runoff to
surface waters. Wind conditions should also be considered to
avoid drift and downwind odor problems. To maximize the value
of nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or
not more than 30 days prior to planting. soil incorporation
of waste will conserve nutrients and reduce odor problems.
D
■

Page 2
The acres needed to apply the animal waste is based on typical
nutrient content for this type of facility. Annual acreage
requirements may be more or less based on the waste analysis
report for your waste management facility.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract Field Soil- Crop- Yield Lbs-N Acres Lbs-N Month -to
No.
No. Type Code /Acre /Unit- ----- Used Apply-
4069 1 NORFOLIC 6.1 50.00 6.2 1891 MAR-OCT
Total 6.2 1891
Available Nitrogen (includes commercial) 1705
Surplus Or Deficit -186
Crop codes: Crop -unit
A=Barley--bu.
_B=Bermudagrass(graze)-tans
C=Bermudaarass(hav)-tons
D=Corn(grain)-bu.
E=Corn(silage)-tons
F=Cotton-lbs. lint
G=Fescue(graze)-tons
H =Fescue (hay) -tons
I=Oats-bu.
J=Rye-bu.
K=Small grain(graze)-acre
L=Small grain(hay)-acre
M=Sorghum(grain)-cwt.
W=Wheat-bu .
Y=Fescue(pasture)-tons
Z=Bermudagrass(pasture)-tons
15 pl-Ari �o �5 1yaT_

Page 3
If more commercial fertilizer is used than shown in this plan,
then additional acres of land may be needed. A three to fifteen
feet wide permanent grass filter strip should be seeded along all
ditches in fields that receive animal waste.
Additional comments:
--------------------
44-- Z ('jCE D1C-1i'(ZE-�iD -DaAW IgC6 CAtA BG: Pt -A -T-Qb XN SMALL
GRAtr1 Frog ADD1T1 or. A(-. Fk eW ZF NEe4E�
'Re5bofza CotAWAO4;)OMlST-
Prepared by: Title: C G�-=M:TW pate: (.jr8)9/.
Concurred in by: r�a" _ _ Date: -3 9
producer
I understand that I must own or have access to equipment,
primarily irrigation equipment, to land apply the animal waste
described in this waste utilization plan. This equipment must be
available at the appropriate pumping time such that no discharge
occurs from the lagoon in a 25--year I -day storm event. I also
certify that the waste will be applied on the land according to
this plan at the appropriate times and at rates that no runoff
occurs.
Date:
Producer
Technical Specialist: ;/. Date: (// L
(Copy to producer and copy to case file)

AM-4aw
MaomaITS 6uTsn :Mq paaedaad
„ r� :.ao-4euJT4sa
:-4aumo
;aaaui6u3
:aqe❑ pTg
:uctgeooj
:.AagwnN
❑132=l .lt)HdS NOSNHOC 3I003 :BuTMe-+O
pasodo.id
;aOe3ans a44 JOJ OJMP .4noquoo aql 30 ImTd
`m. ;mow } • -,� _`m am ;m .�

NJfNi11I r �
WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any discharge of waste which reaches surface water is
prohiibited-
2. There must be documentation in the design folder that the producer either owns or has a notarized agreement for use of
adequate land on which to properly apply the waste. If the producer does not own adequate land to properly dispose of
caste, he/she shall provide a copy of a notarized agreement with a landowner who is -,;gthin a reasonable proximity,
allowing him/her the use of the land for waste application_ It is the responsibility, of the owner of the facility to secure
an update of the Waste Utilization Flan when there is a change in the operation, increase in the number of animals,
method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climate conditions, and level of management, unless there are regulations that
restrict the rate of application for other nutrients. Actual }Melds may be used in lieu of realistic yield tables at the
discretion of the planner.
4. AnirnaI waste shall be applied on land eroding less than 5 tons per acre per year. Waste may be applied to land that is
eroding at more than 5 tons but less than 10 tons per acre per year providing grass filter strips are installed where
runoff leaves the field. (See FOTG Standard 393-Filter Strips)
5. Odors can be reduced by injecting the waste or disking after waste application. Waste should not be applied when there
is danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from the site during application. No ponding should occur
in order to control odor and flies.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the surface is frozen.
9_ Animal waste should be applied on actively growing crops in such a manner that the crop is not covered with waste to
depth that would prohibit growth. The potential for salt damage from animal waste should also be considered
10- Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a high potential for leaching.
Waste nutrient loading rates on these soils should be held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more than 30 days prior to planting of a crop or forages breaking
dormancy..
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following: The outer perimeter of the
land area onto which waste is applied from a lagoon that is a component of a swine farm shall be at least 50 feet from
any residential property boundary and from any perennial stream or river other than an irrigation ditch or canal.
NRCS, NC
NNE, 1996

' WASTE UTII,IZATION PLAN EXHIBIT A-7
REQUIRED SPECIFICATIONS
(continued)
'r*
Animal waste other than swine waste from facilities sited on or after October 1, 1995, shall not be applied closer than
25 feet to surface water. This distance may be reduced for waters that are not perennial provided adequate vegetative
filter strips are present (See Standard 393 - Filter Strips).
12_ Animal Haste shall not be applied closer than 100 feet from wells.
13_ Animal waste shall not be applied closer than 200 feet of dwellings other than those aKned by landowner.
14. Waste shall be applied in a manner not to reach other property and public right-of-ways.
15. Animals waste shall not be discharged into surface waters, drainageways or wetlands by a discharge or by over -
spraying. Animal waste may be applied to prior convened cropland provided it has been approved as a land
applications site by a "technical specialist". Animal waste applied on grassed waterways shall be at agronomic rates
and in a manner that causes no runoff or drift from the site.
v 16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall not be discharged into the
a:.
animal waste management system_
17. A protective cover of appropriate vegetation will be established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to protect the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc. are limited to areas where considered appropriate. Lagoon areas should be kept mowed and
accessible. Lagoon berms and structures should be inspected regularly for evidence of erosion, leakage, or discharge.
.j
18. If animal production at the facility is terminated, the owner is responsible for obtaining and implementing a "closure
plan" which will eliminate the possibility of an illegal discharge, pollution and erosion_
J7 19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular basis to prevent breakdowns,
leaks, and spills. A regular maintenance checklist should be kept on site.
jr
20. Animal waste can be used in a rotation that includes vegetables and other crops for direct human consumption.
However, if animal waste is used on crops for direct human consumption it should only be applied preplant with no
further applications of animal waste during the crop season.
21. Highly visible permanent markers shall be installed to mark the top and bottom elevations of the temporary storage
(pumping volume) of all waste treatment lagoons. Pumping shall be managed to maintain the liquid level between the
markers. A marker will be required to mark the maazmum storage volume for waste storage ponds.
22. Soil tests shall be made every two years and a liquid waste analysis be taken at least twice each year consistent with
waste utilization plan_ Poultry litter shall be tested prior to application_ Soil and waste analysis records shall be kept
for five years.
23. Dead animals will be disposed of in a manner that meets NC regulations.
frr•
MRCS, NC
JL1N£, 1996

LAGOON LIQUID SAMPLING ATTACHMENT"' 6"
L SAMPLE COLLECTION
A. Lagoon Liquid
1 _ Collect approximately 1 /2 pint of recycled lagoon liquid from the inflow pipe to the
flush tanks.
2. From Lagoon
a. Place a small bottle (1/2 pint or less) on the end of a 10-15 foot long pole-
b. Extend the bottle 10-15 feet away from the bank edge.
c. Brush away any floating scum or debris so it is not collected with sample.
d. Submerge the bottle within 1 foot of the liquid surface.
e. Repeat at approximately 5 locations around the lagoon, place into a bucket,
thoroughly mix, and empty I pint into sample container.
3. From a multi -stage lagoon system collect sample from lagoon that is going to be
irrigated from.
II_ SAMPLE PREPARATION AND TRANSFER
A_ Place the sample for analysis into a flexible or expandable container that can be sealed. The
container should be rinsed clean with water and free of any residues but should not be
chlorinated or treated in any other way. Dry litter may also be placed in a sealed plastic bag
such as a freezer bag.
B. The sample should be refrigerated, iced or cooled, if possible or transferred to the lab
immediately.
C. Hand -delivery is the most reliable way of sample transfer, but it can also be mailed.
D. If mailed, sample container should first be protected with a packing material such as
newspaper, then boxed or packaged with wrapping paper and taped.
E. The NCDA Plant Analysis Lab provides this service for a nominal fee of $4 per sample which
should be forwarded along with the sample.
1. Address: NC Department of Agriculture
Plant Analysis Lab
Agronomic Division
Blue Ridge Road Center
Raleigh NC 27611
Phone: [phone]
Attn: Dr. Ray Campbell
F. Request that as a minimum the following analyses be performed:
I. Total nitrogen (TKN)
2. Ammonia nitrogen (NH3-N)
3. Total phosphorus (TP)
4. Potassium (K)
5. Dry litter samples should also include a total solids (TC) analysis.
G. Other analyses performed at no extra cost by the NCDA include trace minerals.

i
I
7
U CC)
Z_
M
ON
CL
0Z
W a
x
i
W H
0 Q
U
W�
m
L'
Q1 N
(L) Qj
�}
cU
JCL
❑ -j W U)
CL
Lf}
r
7
�
� � �� ♦ �a �I nl � � �gj.: ri
•-a '� �� � a,�.):, "r, it a _�
� �.
t
t
~i
r:I
�7 �I r r �
�
v�l _ ^ r.
w
�
♦•Mrt�•k ` � ` p
((ii..
Jv

z
OD
Ig
In
rl
Islolf flirt
It
'

'SHEEN NUMBER 65
WkB (Joins sheet 59)
. e.r. .♦at -..y.- w Wan, B Go" ` w WaR
rIF' 7f Po8! R , `k Go NoB s
R a d
�' \ NOB
•' �!' '� � ' :� .. � � tom• v ,
Wa8 X_ • ti "'" . #j�,. ,Y rf ry WaB F v L
+' GoA
NOA GoA(• � !
O r
GoA Ly'
0. {Rlr' -Pon (� w GoA ; rr 4 { Ra . WaF3 c4 lr Wan"
TV W
Wa$ r• ; -j �- '. L� NOA y}�'jf '=5. _ Yr -•'NOA 1
NnA
1
BB _ Wa\a 1 �. NOB
�1 Nonr fiGZ SB Ra \
R- w .!';•i�a!1'' F -` - 1 n -r t u� trl')� Po$ WaB �L -` I i:• ,a
lruJ
.711
y.�yy�r PoB ~ t WkB
Y Wa6 �' ;. is�r�,sr yy kB
I ' Viai . v . mac'Poe
BB
;
Lu y
� .. 1 f �ca•� _ ! =�nf ` t � ,mow., r w ` , 'i�i -tq-
4!-
r+ Wkr s : �, -• WkB ' 7 Po$ 10
ram' r3`'S'tiA r+ * L/ O
Wa8 r�, � - a � � t, r � r.s _' � o O N
•_. i i �:Et, �,' c 60
'ate }' i.. ' z r t,r.r �. n d C, ?r •F O
- .ka'.f'. •.. �' ~1�. �� r>ti }�� -�a r.v#+;t.,..r � .� - c -FAr, •-�ti,
WkB.a,s WkB
� >" •. ,.'fWaC ti ;-�S"i7�r'c�r i.l {� ti `O" Yam'`:` < 1'ti d 4 ;� aa
14 . .�, , Mi' ` a,' '4ro-c`ayirr+j R� �"� '•FL- 1'•k `�\ O
• P i •'T (r ,,t�j�r�0r l _ • it - '.Tj a 9.P. cq
W1j
a.'Po r
s MaA w t Church I cILI�� p
Ly
NoA NOA• API Q
Wa
CARROLL'S FOODS, INC.
WARSAW NC 28398
NoA
jBCf: MA"iZ GE.Rin Av,4
wing- _ H Rcs _Sous MAP
ration:
lineer:
ner: EbUm No
aw �.,
(Joins sheet 70) 1 11QXIT
I ared By:

'� : jj� �� � fir! �'' • � � � TnNF X
ZONE X
.:--:--ZONE A
s
s a� <X
. 130
45
1; ?
245 f
_ � o
? 1� 9 44
.' ZONE X
t, 44 Mr!! Branch
;ki' 245
1
0
C 4 5 ® O �1
Z
A
s_
} Q�
S� 'x •.
�ZO
0
:}s X
sm
r
Y
f
::::::.................. :::
ZO
i
�•X 45
.3 ' • is{-•: _�: }}�
a
O4
— O
L O . p�14'::•:
Q
O _
CARROLL'S FOODS, INC.
ZONE X WARSAW NC 28398
V4YbKoWGV, UK� Project. µ pt�a.4
�'� ° �ti ® Drawing:yAuD F1mD Pp Map
o 3 0 4o Zo 31 q90 050 Location: a &Seµ
Engineer:
f Owner. ^E! DIE n09SON
Scale: —
Pre aced By: 6N

'•ate q_ r '�+4� ..r �j` ,. 5�+�-." •���,� � ��t 7��, '•F �S � t., �� I g'% ' y � S ��x` , - -' �, tit
NrTZ y_"i-+ -- l �0' -R R it•Y',t�'.. =1;'yf�{ Y -.i v �R,
tiu��' c� �.=fit �.-,,«..iir r-s=` ^� � �!'�'� - �\7�. ��Ks' `a�1F w � _ � �i� ' •r�pT�
�S{ ♦i1. V. ��Y .7r 411k .l'"T,. V�' w . l' 1 � � i y��i•f�'C- ° . t:t�,�r ��1�', � � ; r.�n, �- _ rf +��f ��rP��
r, a'
�A r. a y ; al, r V r\ �a.t `., 1,-. - a� ,✓' y `a.
jj��v'a,� �y� f ...• ar t I L .[.,7 1 a,,. T: �. Y •�'� 'ir s�`4
/r Ii�r�,1}}�1��i�i � }f�ya.y> ieA..j �*! i�'-�y�_��r''.,''yl.l• :�H w'ji�;,� .'+ 1 w: ^I �A... , .,•%w�-=.,.. �-...--- --� {� � 3 ..r .e��.,,� a..
,-i`�- - <lrkS -'F� p •"'aYs' `
Tr�_ti �'^�� lit w: 4 \ F, - ;"� �~ at
0r REC
C
(�_ :3
.. .�s}w,��_y /,,,
•�� y, w..�. i x �,,f.�- �§� - � , - t,�� ,..'-'
�Z';l :� `, 4l `:rYY�'= ;•• y�• r - �. �; l ..aN��" - .- - �.'' Fr ,°�+.��, ,2_, , -: �l
F„sell,
_ :i
Cn
O r `j ' "'�•. f't _ x` .r 4 f •-.i:,l SS t'^F, s a- _ 'r,r F� R��•
Y � > r .�"' ll { i{�,' i4 �r �.. .-''S. �' � n+- = d � s�- � S.t�;-�` ''• � •: =�? ,ls '�'rY
� I � [n F 1. � _ �a r-[ r'.-� 1 t `�' S n .3 - ° ~ 'tea' _ �r�. < '�* �,+-�rs=,-�?: -'-
LA.'_`.y _ r }_r '+ _ •aY'���' r eta. 3 ►j!y.
O ' 'SJ % r •V"'•... /� r1, '>.i. r C rn 1 w l � - •K', a RV � `'
Y, Ix :� �R .�j'�4'! v r'f .l r 1 n kJ'1 t y 'r ih(� .{•. •'1
! P Iv UJKi`�r�
D G?
Gl _ • 1^ 'ti- a r +
..k '+!" \ d' � ', �•` <"(' � �. r y _ - + tic �"?r - �;j �� Lr
co z _m 11 _ r V` ,F r1 �,•L f yf'p•e,
� n (i- � +. •n e t y .../ti # Rom• 'r K
! f Mr►' �.rz + y,1* w� ja;j+•i, lf,r� z-'!. .S` �.. 3 ffi, ;y
� i �• [.�'r� 1 �, ^ c♦ Mti� 4i( �r� o �+;6 Yam,' - ° r i.+ p • 4.3 i,4?.r1.2• ��.1 � ��.: r�+',r ..
� �fP;, � :4 •��s'r`i�� '-' �rnY :iyr f - �fJs7w J' r sr ?�t''Hrr?�ty°� y, Y �tw�'r'L
' 'i'a e T, + f! .yit•y ���y-,`rti �rartZe r ti tr '�;c''� �rK• W`.:..
•� S x .,i"7 , e ''" rC s �,y�+i• r 1 � `ia' � � \, ,., `r/y r It �,� yr �, ,�,� Ja": 65,�':.
a y'4FF .. .t:�`.Jr \�•' ,.�.ti . jy,.�'.a - r`�ri. `J*4 } ,`.b�t+yt,; 's i``l•-+A'L+_•�4:Rty6ty .r" 'y _ r
I � '. :� nL. �i.'F.tlxwl'i/•�; �w\ �` .+�,�, hR}„',t r�}�,�,� i"-Sf a. Eriy �.w -r .�_r � rl rf' J + •r .�:� _ii f + L�,:}a^yt�#d .ra�if 4�4+ � ,�N '.r '�
' ' ' rr, _ �? _• }aa_ r f�;a `Z r � !
�, rf,►+x^jt ! � ., 1�:. '_ri�'a � .. � '�4'� t; ra v�v ,r n . . •� � r ~ ' i� •' ''/'?�•'.
,+ l O �' ''+ .� � r •ram _'}' y � .4''.. 1 r.•� -•

' R ; I ". i '! i/ a c9 U 7 Si-.R, 'c x
;F@ V o- -��Q9 ' i-' r �' `i7{� �� . #� ';'otl r q �cD i i� • . •R+': ° Cp . @ .C, �. rf..
�'' r, ~ ^� - Oj ( :> G c-- - °•cc��,,C,'it'c �1'v^. ��• a <c `� o $ ., a��! 2 ��. .n',i]' -!' _ '••"t1
1, �� h � �O!�.�� � �`d1.�c�,� tiT'�i,.``SS c 4,,d'�. �`?/��•i_'`„ir�-rr �.�i) �U�ig, '�..� .✓ri �+' �"�� :0. �� q,n �p ,
+'J / ,�, ���� " '� y�1,�,0`�p ,���,: � ,;y'�.a _t•F'.S� �S! r„ ^'?F�G ..� �`� "� ."'S' 9 '�stia °
JRt4js
fill
wd
f�,
,� o� �4 � ti_ �3' `Fr��,'�c`t.5:i.�['�.� _o _:��7[Y_:'.�. �• �� '
.'}[qrii ,Y 1A �z'•+at'' ,' p`, p,.y,;s. - G ry_ o ,i8 _.n,. JacK.,r 3. K5lx `� -;'- c 'Z� 8.".45'' r ���'qq ••_'^ r
pc�,: 1 n� t L' cc' ✓ 'i" c Ga 'ry - r �Cc S4. k� 7 `� RS'd � q � c'l __
„% r✓ (^ q 1t - iS b,'r .ht d' - tUo c 4T c��.
LT
' �t". - c+ �; l: V . i,:._ `�� oa p+i7� y- �1�� a QG����"•aA�C4� �� �c a !7 i A 'MCn '� Dr*" r
1x i°; •�'� rry' . ,:— �' "1 '�-`'1 ' s r o / town °� 4J. _ U7 • b "O .
lam-' t- ,rry' r.�,e• °7 6r4f �' ° c{.
'y y-.p ��tip /.�J'*!- f 3 24 4 �,, � -T [.' �. ,r � 4`{.1� ��' � h�A �` Y' 7�.��,yf� �.•
1 � rY ��'` �- A'�r�'' !�� -.�' �t � 4ry ��• �. �k� 1.7'1 C �� 5�._ 4 s .�i �� `1�'j�j j,��C��r. ..4 .a C�L1. \tit:y � .� a°� ���'-Q 'J hr• � 1... r'..�'
.�.
•wi ; tk G + y qr 1 r ` %t `t- { t S�nY iI, 3 ] sty L� ` C,� .'t� i` ► •4y .y u ryq'l�c� rl y ° r � :�a', 5!U l� .
C 3 o V
�. 41�Y' j r O �1� Y tiJ by
r a. ti' <, ,� ., � y ' o FOP • � : - �j ..I�, .' a a r `.r -� •„ 4 'Y f z r w 2F4.
c 1 ,.ij.: _ n� ; f i , r - aCy - " - - ° eg lb'ya •,i , ,
"a�•�V.`,�{,p7 �'�.�� ro. •_Om,y�.�p"4,a" aAV'.e'E 3a'R°":.
as '', °
�1 aCQr`Li o. 7V q t«o t CQZ� i CG7�� �) y J,� s'dpn Ct rt` a �?. 0880�1
«:. (YClSaIt
J ` As ` .� }• I� r r• } 4.' °� ,� �� .� .iiQ du £� ^ r�-: G ^'dk. ` Q.• .� .,7 - = r„1 �3'�`J: ;�-y'l;"
e #', ' 4 }. :1 WY. ,..` {j , -Y e. C�G,'�. S .1'i.1S '4. Al - 5 {
'c `-A. t , . is LLLi b , R.'+'• ' , c s��+:. l may. rn'va �10rb �.
� ° � �;� �,E��.s7 ' e .•f1 ' � � `.�v _ � c c}b �.. �r4, pp,' a0�? e u -.� a ,i y�{�•l r I a
o n S 3;� o S �O � iy� . � . 0. .P•i. �:- c C •`� � a� A. � o'+' b,t�
41
Vic
� - r � u� �5- r �,�, f._F3 -; "V �- .. ° .� `":� �+ �T• r r "` i9 , � � r ��.+}�"t�',.. a' C o Ly ... �
. 3.
�-.:t1 � '. t� �f' ,�A._ '` ' 'o ,.. J,- t��' � �y ° co�,t+r-,..- p..
`�
n c c �n roc C i. .!^;� r w - ' y 4i t i ',]+. •ra, 7,� , n �:� d� 1 oo� a '`A }�,d,
� -° O,: 1 � •= �Ts(�
Jr'n'n. �f ♦ :i° o-' �.. Ui]1� "'- .7� - c c± �}1 "�''!-j. Fc�,. rt '�.., o`Z ..vvh'°°�, a`�_.- ."� 'r� ~�. l,-a'
'( Y, <`t* uY F' -q, �-� 4F���•r?-.�+' 'r' '. '. C , ii yf Il ! ! �• ,th - '.i_ , ep: � � U .f' r 'S. r. - ., cs �.0 - � - Ile n)
J�f fy 1 i` `s J `-' , �.J O -�i- -w, - R,<i nY-",.lW-d�-c..�A•` t4�' c ' 9r •_`: icy_' , A , 1 �a3�' l •:v , j nr � t Y? c` r � �� �, ', � ? (� 'k" . � cYS� C. 4' n �a. �ti�7�t �, � � �. ` t+� �.: `
, `c' r e o ' ` , o „�"i (a T�. '� � � 'f r, " •^. � "'l ° `� � J s.4r4 .}i . o ° ,�`' q �'-m �I�:` h•r:� T� �7 F p� �34: D ;
,`•,u ' `�-.,t o �� , ,t. .f F.t..p'. - o. F)'' �� .4.j ,' �� ° ��.r _ �'h!1- �% re
ld n
'yF �` N Dtt _f ` o r .r% L t�7 ���� � iK � � ���� ���.t�i k�� : � �� O 1. �`"D ° ��� Pr' i c �p�Q-' �•���c .c�� S'.-yyt� .b, 1 �H.ei r':
Wr
� a '. c 2+ is n� / , .,�11 .r '( a 1"i�, .,ram -r � - • {,c�"Y ' � ' 71 � -t�r"7 � ° �ir'C4r� "'� > - ; . do a' eS � �a'� p% d' -.l) �� s,
/1� j'4, a o cam, a° Q
- 1 �� o•y ti - I l rr 1.,�d !
�xi4.` �I 1.;1� �. � �:r e�� o� m � ��s• �; � ��a` ��-t;'l, �,;. ,7: t y,�, Fj'� � .� ,�.rrtf �} y csu, •o �
u. a:�v
IiO. to
J.d `�_0.'�" r'�'r a �yt• _t •�A c _ J . } ,e- ,s �V�.1 -s.b r 6 r� -ti _ oopan •'fd' n'. Ij_
S ? 4.• ay y �. 1 ` 1' L 13 x a o n 9
i.+`
�• � .t�.,,, rr'� i T � . ' �` fic •.' ; r r c )�} bt ��, "�` ^ 'e a . _ lya+" � ; Z' . o /f � � �' r - �:f2 .� , " -:\, r e � ��{� '�;�, 5 ", °i4�o a °� ��: �, ��o o , o
`'� �:: N � .,•� ,r�ti �� �c :. -�" � !n � �' i''r`h'1 � ' jj+ .`I �.i;, � ' G'�v eo - �b ,
t ' �3 ' .� .e; rx p c L ��1' yr- •s%�r J 'i.' `.
�1T {• ^1' �, Or T � �� • r� Wit. '�- �3� g J;c� Era' �F .. ,S `Y� � o`. 1.3i" , r' y�' � . � ` 'fir G° ca •J �,
•/y _ r {�, h ,fit, ;. `'?�! .' "{ 1'7' " ' c` - -'•n - �' $ c; c. s' X Vjty s'S�c:
Few ` � �I v
v Id
t.

DEC.14.2000 11:10AM CVRROLL'S FOODS
N0.158 P.1
'a --
CARROLL'S FOODS, INCIr
P. a. Drawer 8G6
a8aa WARSAW, NORTH CAROLINA 28398
FAX TRANSMITTAL SHEET
1
DATE: o 0
TIME:
TO: -7 maq ESA 1yi47'E,4
FROM: 4WAAW 4,A 5 P m -
FAX NUMBER: _ L `fit!_ 7-s -- _a-i 8
N-UMBER OF PAGES:
SUBJECT: him em$
fL gt(--

DFC.A4.2000 11:104 CJ4?ROLL'S FOODS NO.168 P.2
`-rtA S :5 'Stile F--r-- W !T'H Ya U iZ ulA5-17E L�T3L Z 4T7 oK
PLA,"
13�ac•
Page 5 UX;)C--
APPLICATION OF TASTE tY IRRIGATION
The irrigation application rate should not exceed the intake rate
of the soil at the time of irrigation such that runoff or ponding
occurs. This rate is limited by initial soil moisture content,
soil structure, soil texture, water droplet size, and organic
solids. The application amount should not exceed the available
water holding capacity of the soil at the time of irrigation nor
should the plant available nitrogen applied exceed the nitrogen
needs of the crop.
If surface irrigation is the method of land application for this
plan, it is the responsibility of the producer and irrigation
designer to ensure that an irrigation system is installed to
properly irrigate the acres shown in tables. Failure to apply the
recommended rates and amounts of nitrogen shown in the table may
make this plays invalid. ,
The following table is provided as a guide for establishing
application rates and amounts.
Tract Field Soil
No. No. Type crop
4069 1 NORFOLK CB HAY
Applic
Applic
Rate
Amount
(in/hr)
(inches)
-----
--====
0.50
1.00
This is the maximum application amount allowed for the soil

Z 11 it
DEC.14.2000 11-IOSM CPoUKLL'S FOODS NO.169 P.2
�N5ERr TH+� StiC T
Page- 5---_�_
2{ IM zaoo
w tTN YaL) K WA-5r -L LMLC ZATr ON
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate
of the soil at the time of irrigation such that runoff or ponding
occurs. This rate is limited by initial soil moisture content,
soil structure, soil texture, water droplet size, and organic
solids. The application amount should not exceed the available
water holding capacity of the soil at the time of irrigation nor
should the plant available nitrogen applied exceed the nitrogen
needs of the crop.
If surface irrigation is the method of land application for this
plan, it is the responsibility of the producer and irrigation
designer to ensure at an irrigation system is installed to
properly irrigate the acres shown in tables. Failure to apply the
recommended rates and amounts of nitrogen shown in the table may
make this plan invalid.
The following table is provided as a guide for establishing
application rates and amounts.
Applic
Tract Field Soil bate
---
---_ -No: —_ Type Crap ... - ( inyhr)
4069 1 NORFOLK CB HAY 0.50
Applic
Amount
___( i.nches )
1.00
OA
This is the maximum application amount allowed for the soil

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Eddie Johnson
Eddie Johnson #2
905 White Pond Road West
Fairmont NC 28340
Farm Number: 78 - 87
Dear Eddie Johnson:
1 • •
NCDENP*
NORTH GAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
October 23, 2000 j} Ci- iE-+14 V
oc 1 2 s 2000
Y,, 3 , . J- EW LLE
REG. OFFICE
You are hereby notified that Eddie Johnson #2, in accordance with G.S. 143-215.10C, must apply for coverage under
an Animal Waste Operation General Permit. Upon receipt of this letter, your farm has sixty (60)_days to submit the attached
application and all supporting documentation. In accordance with Chapter 626 of 1995 Session Laws (Regular Session
1996), Section 19(c)(2), any owner or operator who fails to submit an application by the date specified by the
Department SHALL NOT OPERATE the animal waste system after the specified date_ Your application must be
returned within sixty (60) days of receipt of this letter_ Failure to submit the'application as required may also subject your
facility to a civil penalty and other enforcement actions for each day the facility is operated following the due date of the
application.
The attached application has been partially completed using information listed in your Animal Waste Management
Plan Certification Form. If any of the general or operation information listed is incorrect please make corrections as noted on
the application before returning the application package. The signed original application, one copy of the signed application,
two copies of a general location map, and two copies of the Certified Animal Waste Management Plan must be returned to
complete the application package. The completed package should be sent to the following address:
North Carolina Division of Water Quality
Water Quality Section
Non -Discharge Permitting Unit
1617Mail Service Center
Raleigh, NC 27699-1617
If you have any questions concerning this letter, please call Theresa Nartea at [phone] extension 375 or
Jeffery Brown with the Fayetteville Regional Office at [phone].
cerely,
for Kerr T. Stevens
cc: Permit File (w/o encl.)
Fayetteville Regional Office (w/o encl.)
1617 Mail Service Center, Raleigh, NC 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

State of North Carolina
Department of Environment
and Natural Resources
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
August 1, 2000
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Eddie Johnson
Eddie Johnson #2
905 White Pond Road West
Fairmont NC 28340
/ •
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
NEC -
AW 7 2000
FAYE7i E V)LLE
REG. O��iCE
Subject: Notification for Wettable Acre Determination
Animal Waste Management System
Eddie Johnson #2
Facility Number 78-87
Robeson County
Dear Eddie Johnson:
A letter dated January 15, 1999 was sent to advise you about concerns associated with Certified Animal
Waste Management Plans and the method by which the irrigated acres within the plans were calculated. Only
the acres that are wetted can be credited in the waste management plan as receiving waste application. Any
acreage within the plan that can not be reached by waste application equipment can not be used as part of your
plan.
An evaluation by John Hasty on 2/16/99 was made to review the actual number of acres at your facility
that receive animal waste during land application. The evaluation of your facility has yielded one of the
following two results as indicated by the box marked with an "X".
Category 1:
❑ The evaluation of your facility could not be completed due to a lack of information. Please
contact your Technical Specialist to assist in providing John Hasty the necessary
information to potentially exempt your facility from undergoing a complete wettable acre
determination. Please submit this information to John Hasty, at 225 Green Street, Suite
714, Fayetteville, NC 28301, within in 90 days of the receipt of this letter. If you have any
questions please contact John Hasty at [phone]. If within 90 days you are unable
to provide John Hasty with the information you are automatically required to complete
a Wettable Acre Determination as described by Category 2 below, within 180 days
of receipt of this letter.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone 9I9-733-5083 Fax [phone]U8
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

Notification for Wettable Acre Determination
Animal Waste Management System
Page 2
Category 2:
Your facility has been identified by the Department of Environment and Natural Resources
as a facility that may have overestimated the number of acres actually receiving animal
waste. Therefore, some or all of your fields may be exceeding the allowable loading rates
set in your Certified Animal Waste Management Plan.
In order to resolve this issue, please contact a designated Technical Specialist to have him
or her conduct a Wettable Acre Determination for your facility. The Technical Specialist must
be one that has been approved by the Soil and Water Conservation Commission to conduct
Wettable Acre Determinations. Many Technical Specialist with the N.C. Cooperative Extension
Service, the Soil and Water Conservation Districts, the Natural Resources Conservation
Service, and the Division of Soil and Water Conservation have received this special
designation. You may also contact a private Technical Specialist who has received this
designation, or a Professional Engineer.
All needed modifications to your Animal Waste Management System must be made and
the Wettable Acres Determination Certification must be returned to DWC within the next
180 days. If the needed modifications are not made and if the form is not returned within the
required time, DWQ will be forced to take appropriate enforcement actions to bring this facility
into compliance. These actions may include civil penalty assessments, permit revocation,
and/or injunctive relief.
Once a Wettable Acre Determination has been completed, a copy of the attached Wettable
Acre Determination Certification must be submitted to the address listed on the form. Please
note that both the owner and the Technical Specialist must sign the certification. A copy of all
the Wettable Acre Determination documentation that applies to your Waste Utilization Plan
must be kept at your facility. DWQ and the Division of Soil & Water Conservation Staff will
review all documentation during their annual visit of your facility. An additional copy must by
kept on file at the local Soil & Water Conservation District Office. Please note that if you install
or modify your irrigation system, a designated Irrigation Specialist or a Professional Engineer
must also sign the Wettable Acre Determination Certification.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Sonya Avant of our
Central Office staff at [phone] ext. 571.
Sincerely,
Kerr T. Stevens
cc: Fayetteville Regional Office
Robeson County Soil and Water Conservation District
Facility File

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
Eddie Johnson
Eddie Johnson #2
Rt 1, Box 443
Fairmont NC 28340
Dear Eddie Johnson:
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
December 30, 1999 Il ® E I -Avr; E 1_J
Fr1YE"i I EVILS
REG.07 SCE
Subject: Fertilizer Application Recordkeeping
Animal Waste Management System
Facility Number 78-87
Robeson County
This letter is being sent to clarify the recordkeeping requirement for Plant Available Nitrogen (PAN)
application on fields that are part of your Certified Animal Waste Management Plan.
In order to show that the agronomic loading rates for the crops being grown are not being exceeded, you
must keep records of all sources of nitrogen that are being added to these sites. This would include nitrogen
from all types of animal waste as well as municipal and industrial sludges/residuals, and commercial fertilizers.
Beginning January 1, 2000, all nitrogen sources applied to land receiving animal waste are required to
be kept on the appropriate recordkeeping forms (i.e. IRR1, IRR2, DRY1, DRY2, DRY3, SLUR1, SLUR2,
SLDl, and SLD2) and maintained in the facility records for review. The Division of Water Quality (DWQ)
compliance inspectors and Division of Soil and Water operation reviewers will review all recordkeeping during
routine inspections. Facilities not documenting all sources of nitrogen application will be subject to an
appropriate enforcement action.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Ms. Sonya Avant of the
DWQ staff at [phone] ext. 571.
Sincerely,
Kerr T. Stevens, Director
Division of Water Quality
cc: Fayetteville Regional Office
Robeson County Soil and Water Conservation District
Facility File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50%D recycled110%a post -consumer paper

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Eddie Johnson
Eddie Johnson #2
Rt 1, Box 443
Fairmont NC 28340
Dear Eddie Johnson:
4 •
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NAruRAL RESOURCES
December 6, 1999
RECEIVELD
1999
FgfEITEVILLE
RAC- ir=10E
Subject: Conditional Approval
Animal Waste Management System
Facility Number 78-87
Robeson County
Our records indicate that your facility was conditionally certified in order to fulfill the requirements
of completion of your Certified Animal Waste Management Plan Certification. This letter is to inform you
of your unresolved conditional approval status. Any facility receiving a conditional approval must notify
Division of Water Quality (DWQ) in writing within 15 days after the date that the work needed to resolve the
conditional certification has been completed. Any failure to notify DWQ as required, subjects the owner to
an enforcement action. As of December 6, 1999, we have no record of any information from you, advising
us of the status of your conditional approval. Therefore, please fill out the attached form and have your
technical specialist and landowner sign the form in the appropriate areas.
The completed form must be submitted to this office on or before 45 days of receipt of this letter.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or liability
for failure to provide DWQ with proper notification of your conditional certification status or possible failure
to comply with the requirement to develop and implement a certified animal waste management plan by
December 31, 1997_
If you have any questions regarding this letter, please do not hesitate to contact me at [phone]
extension 571.
Sincerely,
Sonya L. Avant
Environmental Engineer
cc: Fayetteville Regional Office
Robeson County Soil and Water Conservation District
Facility File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycle&10% post -consumer paper