780012_CORRESPONDENCE_20171231

WASTE UTILIZATION PLAN
NPDES PERMIT itENEWAL - 2007
REGIONAL OFFICE - APS
FARM NO: 7$- 00�2
❑ ASHEVILLE
FAYETTEVILLE
❑ MOORESVILLE
❑ RALEIGH
❑ WASHINGTON
❑ WILMINGTON
❑ WINSTON-SALEM

Y7 aterResources
ENVIRONMENTAL QUALli V
RECEIVED
DEQIDWR
August
Murphy -Brown LLC AUG 18 Z916
Farm 5572
PO Box 856 WQROS
Warsaw, NC 28398 q TE�!!t_E E �GIONAL OFFICE
Subject:
Dear Murphy -Brown LLC:
PAT MCCRORY
DONALD R. VAN DER VAART
sccrvayy
S. JAY ZIMMERMAN
12, 2016
Certificate of Coverage No. AWS780012
Farm 5572
Swine Waste Collection, Treatment,
Storage and Application System
Robeson County
rire_1or
In accordance with your August 5, 2016 request to change operation type without exceeding the permitted
steady state live weight, we are hereby forwarding to you this Certificate of Coverage (COC) issued to
Murphy -Brown LLC, authorizing the operation of the subject animal waste management system in
accordance with General Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management Plan
(CAWMP) for Farm 5572, located in Robeson County, with a swine animal capacity of no greater than the
following annual averages:
Wean to Finish: Feeder to Finish: 12,595 Boar/Stud:
Wean to Feeder: Farrow to Wean: Gilts:
Farrow to Finish: Farrow to Feeder: Other:
If this is a Farrow to Wean or Farrow to Feeder operation, there may be one boar for each 15 sows. Where
boars are unnecessary, they may be replaced by an equivalent number of sows. Any of the sows may be
replaced by gilts at a rate of 4 gilts for every 3 sows.
This COC shall be effective from the date of issuance until September 30, 2019, and shall hereby void
Certificate of Coverage Number AWS780012 dated October 1, 2014. Pursuant to this COC, you are
authorized and required to operate the system in conformity with the conditions and limitations as specified
in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting and
maintaining the required monitoring data and operational information must be established for this facility.
Any increase in waste production greater than the certified design capacity or increase in number of animals
authorized by this COC (as provided above) will require a modification to the CAWMP and this COC and
must be completed prior to actual increase in either wastewater flow or number of animals.
Please read this COC and the enclosed State General Permit carefully. Please pay careful attention to the
record keeping and monitoring_ conditions in this permit. Record keeping forms are unchanged with this
General Permit. Please continue to use the same record kegpin forms.
orms.
If your Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
State of North Carolina I Environmental Quality I Water Resources
1636 Mail servkc Ccnter I Raleigh. North Carolina 27699-1636
919 $07 6464

The issuance of this COC does not excuse the Pennittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federalj,-nor :does. issuance of a COC to operate
under this permit convey any property rights in either real or personaTproperty.
Per NRCS standards a 100-font separation shall be maintained between water supply wells and any lagoon,
storage pond, or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified;in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or'penalties in.accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminalpenalties, and injunctive relief.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Program for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition 11.22 of the General Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Tropical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You may
find detailed watch/warning information for your county by calling the Wilmington, NC National Weather
Service office at (910) 7624289, or by visiting their website at: htt-Hwww.weather.gov/ilm/
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office staff
may be reached at 910433-3300. If you need additional information concerning this COC or the General
Permit, please contact the Animal Feeding Operations Program staff at [phone].
Sincerely,
Lor S. Jay Zimmerman, P.G.
Director, Division of Water Resources
Enclosure (General Permit AWG 100000)
cc: (Certificate of Coverage only for all ccs)
Fayetteville Regional Office, Water Quality Regional Operations Section
Robeson County Health Department
Robeson County Soil and Water Conservation District
WQROS Central Files (Permit No. AWS780012)

Murphy -Brown 1LC
January 21, 2010
Aquifer Protection Section
NCDENR, DWQ
Fayetteville Regional Office
225 Green Street
Suite 714 / Systel Bldg.
Fayetteville, NC 28301-5043
Subject: Burial Site Map for
Farm 5572, (Old Farm #7572); Fac. No.: 78-12
Robeson County
PO Drawer 856
2822 Hwy. 24 West
Warsaw, NC 28398
Tel. [phone]
Fax_910-293-3138
RECEIVED
JAN 2 7 2011
DENR4AYE7TFV1I.10 REGIONAL OFHCE
Enclosed please find a copy of the map of the burial site for the above -mentioned facility where from
November 22, 2010 January 7, 2011, 1030 feeder -finish pigs were buried in accordance with the facility's
CAWMP and the NCDA&CS Veterinary Division's Statutes and regulations. Please place in the
appropriate files.
If you have any questions regarding this matter, please do not hesitate to call me at [phone] ext.
5363.
Sincerely,
Kevin Weston, CID
Environmental Compliance
Cc: Murphy -Brown, LLC Files

s
Form 5572
a-
Total Field = 14.75 Ac.
r. Hog Houses
and
Lagoon
Wells w/100' offsets
C�—
x:
S� r�
Total Field 33.33 Ac. it/Zz/z�v
Total Field = 70.36 Ac.
Zc yiP
� Q
Ir
aIx
q�
Ix
�a�

Murphy -Brown, LLC 3/29/2001 2822 Hwy 24 West
P.O. Box 856
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Grower(s): Murphy -Brown, LLC
Farm Name: 5572
County: Robeson
Farm Capacity:
Farrow to Wean
Farrow to Feeder
Farrow to Finish 1200
Wean to Feeder
Feeder to Finish
Storage Structure: Anaerobic t
Storage Period:
Application Method:
>180 days
Irrigation
.agoon
RECEIVED I DENR I DWQ
AQUIFFP-PRnTFnnN SFCTION
DEC 2 7 2006
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water andlor groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
f� T
�!
Z
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
a t `9
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
C= r ii
less than 10 tons per acre per year providing that adequate filter strips are established.
ti
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft tons, etc.):
Ca aci Type Waste Produced per Animal Total
Farrow to Wean
3212 gallyr
gallyr
Farrow to Feeder
4015 gallyr
gallyr
1200
Farrow to Finish
10585 gallyr
12,702,000 gallyr
Wean to Feeder
223 galtyr
gallyr
Feeder to Finish
986 gallyr
gallyr
Total 12,702,000 gallyr
AMOUNT OF PLANT AVAILABLE. NITROGEN PRODUCED PER YEAR (lbs):
Capacity Type Nitrogen Produced per Animal Total
Farrow to Wean
5.4 lbslyr
Ibslyr
Farrow to Feeder
6.5 lbslyr
Ibslyr
1200
Farrow to Finish
26 Ibslyr
31,200 Ibslyr
Wean to Feeder
0.48 Ibslyr
Ibslyr
Feeder to Finish
2.3 lbslyr
lbslyr
Total 31,200 Ibslyr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 141.56
Total N Required 1st Year: 42681.99
Total N Required 2nd Year: 38843.51
Average Annual Nitrogen Requirement of Crops: 40,762.75
Total Nitrogen Produced by Farm: 31,200.00
Nitrogen Balance for Crops: (9,562.75)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2 of 8

Reception Area Specifications
Tract Field Irrigated Soli 1st Crop Time to 1st Crop 1st Crop Lbs NlAc Lbs N Total iba N
Acreage Type Code Apply Yield Ibs NlUnit Residual /Ac Utilized
2nd Crop Time to 2nd Crop 2nd Crop Lbs NlAc Lbs N Total ibs N
Coda Apply Yield Ibs NlUnit Residual /Ac Utilized
Total
Lbs NlAc
Total Ibs N
Utilized
34569
1
5.35
Pocalla
C
Mar -Sat
5.0
50
250
1337.5
L
1
50
50
267.5
300
1605
2
4.26
Pocalla
C
Mar -Se 1
5.0
50
250
1065
L
1
50
50
213
300
1278
3
3.4
Pocalla
C
Mar -Sot
5,0
50
250
860
L
NSept-Apr
1
50
50
170
300
1020
4A
3,47
Pocalla
C
MarSe t
5.0
50
250
867.5
L
1
50
50
173.5
300
1041
6
4B
5.12
Pocalla
C
MarSe t
S0
50
250
1280
L
1
50
50
256
300
1536
34569
SA
6.36
Pocalla
C
Mar -Set
5.0
50
250
1595
L
1
50
%
319
300
1914
6
1 5B
6.33
Pocalla
C
Mar -Set
5.0
1 50
250
1582.5
1 L
Sept -Apr
1
1 50
50
316.5
300
1899
6A
4.82
Pocalla
C
Mar -Sept
5.0
50
250
1206
L
Sept -Apr
1
5o
50
241
300
1446
66
1.87
Pocalla
C
Mar -Sot
5.0
50
250
467.5 i
L
Sept -Apr
1
50
50
93.5
300
561
7A
3.05
Pocalla
C
Mar -Set
5.0
50
250
762.5
L
Sept -Apr
1
50
50
152.5
300
915
76
4,71
Pocalla
C
Mar -Sot
5,0
50
250
1177.5
L
Sept -Apr
1
50
50
235.5
300
1413
6A
4.71
Pocalla
C
Mar -Set
510
50
250
1177.5
L
Sept -Apr
1
50
50
235.5
300
1413
8B
2.9
Pocalla
C
Mar -Sept
5.0
50
260
725
L
Sept -Apr
1
50
50
145
300
870
9A
4.64
Pocalla
C
Mar -Set
5.0
50
250
1160
L
I Sept±er
1
50
50
232
300
1392
9B
42
Pocala
C
Mar -Set
5.0
50
250
1075
L
Sept -Apr
1
50
50
215
300
1290
10A
3.48
Pocalla
C
Mar -Set
5,0
50
250
870
L
Sopt-Apr
1
50
50
174
300
1044
10B
2.86
Pocalla
C
Mar -Set
5,0
50
250
715
-L
S@ t-A r
1
50
50
143
300
858
34569
11
2.13
Wa ram
C
Mar -Set
5.5
50
275
585.75
L
Sept -Apr
1
50
SO
105.5
325
692.25
12
1 2.14
Waf1ram
C
Mar -Set
5.5
50
275
58B.5
L
Sapt-Apr
1
50
50
107
325
695.5
13
2.14
Wa ram
C
Mar -Sept
5.5
50
275
5B8.5
L
Sept -Apr
1
50
5o
107
325
695.5
14
2.81
Wa ram
C
Mar -Set
5.5
50
275
772.75
L
Sept -Apr
1
50
50
140.5
325
913.25
15
2.48
C
Mar -Set
5.5
50
275
682
L
Sept -Apr
1
50
50
124
325
806
16
2.14
C
Mar -Set
5.5
50
275
588.5
L
Se t-A r
1
50
50
107
325
695.5
17
2.7
C
Mar -Set
5,5
50
275
742.5
L
Se t-A r
1
50
50
135
325
877.5
18
2.63
MWaram
C
Mar -Set
5.5
50
275
723.25
L
Se t-A r
1
50
50
131.5
325
854.75
19
3.73
C
Mar -Set
5.5
50
'275
1025,75
L
Se t- r
1
50
50
186,5
325
1212.25
20
4,61
C
Mar -Sat
5.5
50
275
1267.75
L
SB t- r
1
50
50
230.5
325
1498.25
21
1.91
C
Mar -Sept
5.5
50
275
525.25
L
So t- r
1
50
50
95.5
325
620.75
22
4.97
Wa ram
I C
Mar -Set
5.5
50
275
1366.75
L
Sept -Apr
1
5o
SO
248.5
325
1615.25
23
3.58
Wa ram
C
Mar -Set
5.5
50
1 275
984.5
L
Sept -Apr
1 1
50
50
179
325
1163.5
24
2.92
Wa ram
C
Mar -Set
5.5
50
275
803
L
-Sept-Apr
1
50
50
146
325
949
Sub6.10
0.42
Pocalla
C
Mar -Set
5.0
50
250
105
L
Sept -Apr
1
50
50
21
1 300
126
Subll-20
6.27
Wa ram
C
Mar -Set
5.5
50
275
1724.25
L
Sept -Apr
1
50
50
313.5
325
2037.75
Sub21-24
2.15
Wa ram
C
Mar -Set
5.5
50
275
591.25
L
Sept -Apr
1
50
50
107.5
325
69B.75
Sub 25
10.87
We ram
N
Sept.-Apr1l
40.0
2.4
96
1043,52
O
Jun -Set
25
4
100
1087
i96
2130.52
Sub 26
9.31
Goldsboro
N
Sept, -April
60.0
2.4
1"
1340.64
0
Jun -Sept
42
4
168
1664.06
312
2904.72
Totals: 141.56 33961.91 8720.06 42681,99
3(e) of 8

Reception Area Specifications
Tract Field Irrigated Soil 1st Crop Time to 1st Crop 1st Crop Lbs NlAc Lbs N Total Ibs N
Acreage Type Code Apply Yield Ibs NlUnit Residual /Ac Utilized
2nd Crop Time to 2nd Crop 2nd Crop Lbs WAc Lbs N Total Ibs N
Code A I Yield Ibs NlUnit Residual lAc Utilized
Total
Lbs NIA c
Total Ibs N
Utilized
34569
1
5.35
Pocalla
C
Mar -Sept
5.0
50
250
1337.5
L
Sept -Apr
1
50
50
267.5
300
1605
2
4.26
Pocalla
C
Mar -Set
5.0
50
250
1065
L
Sept -Apr
9
50
50
213
300
1278
3
3.4
Pocalla
C
Mar -Sat
5.0
50
250
850
L
Se t-A r
1
50
50
170
300
1020
4A
3.47
Pocalla
C
Mar -Set
5.0
50
250
867.5
L
Sept -Apr
1
50
50
173.5
300
1041
6
4B
5.12
Pocalla
C
Mar -Sat
5.0
50
250
1280
L
Sept -Apr
1
50
50
256
300
1536
34569
5A
6,38
Pocalla
C
Mar -Set
5.0
50
250
1595
L
Sept -Apr
1
5o
5o
319
300
1914
6
513
6.33
Pacalla
C
Mar -Set
5.0
50
250
1582.5
L
Se t-A r
1
50
50
316.5
300
1899
6A
4.82
Pocalla
C
Mar -Set
5.0
50
250
1205
L
Sept -Apr
1
50
50
241
300
1446
6B
1.87
Pocalla
C
Mar -Set
5.0
50
250
467.5
L
Se !-A r
1
50
50
93.5
300
561
7A
105
Pocalla
C
Mar -Set
5.0
50
250
762.5
L
Sept -Apr
1
50
50
152.5
300
915
7B
4,71
Pocalla
C
Mar -Set
5.0
50
250
1177.5
L
Se t-A r
1
60
50
235.5
300
1413
SA
4.71
Pocalla
C
Mar -Set
5.0
50
250
1177.5
L
Sept -Apr
1
50
5o
235.5
300
1413
8B
2.9
Pocalla
C
Mar -Sept
5.0
50
250
725
L
Sept -Apr
1
50
50
145
300
870
9A
4.64
Pocalla
C
Mar -Sept
5.0
50
250
1160
L
Se t-A r
1
5o
50
232
300
1392
9B
4.3
Pocalla
C
Mar -Set
5.0
50
250
1075
L
Se t-A r
1
50
50
215
300
1290
10A
3.48
Pocalla
I C
MarSe 1
5.0
50
250
870
L
Se t-A r
1
54
50
174
300
1044
108
2.86
Pecalla
C
Mar -Set
510
50
250
715
L
Se t-A r
1
50
50
143
300
858
34569
11
2.13
wa ram
C
Mar -Set
5.5
50
275
585.75
L
Se t-A r
1
50
50
106.5
325
692,25
12
2.14
Wa ram
C
Mar-SeLL
5.5
50
275
588.5
L
Se t-A r
1
50
50
107
325
695.5
13
2.14
Wactrarn
C
Mar -Set
5.5
50
275
588.E
L
Se t- r
1
50
50
107
325
695.5
14
2.81
Wa ram
' C
Mar -Se 1
5.5
50
275
772.75
L
Sept -Apr
I 1
5o
5o
140.5
325
913.25
15
2,48
Wa ram
C
Mar -Set
5.5
50
275
682
L
Sept -Apr
1
50
50
124
325
806
16
2.14
Wa ram
C
Mar -Set
5.5
5o
275
588.5
L
Sept -Apr
1
50
5o
107
325
695.5
17
2.7
Wa ram
C
Mar -Set
5.5
50
275
742.5
L
Sept -Apr
1
50
50
135
325
877.5
18
2.63
Wa ram
C
Mar -Set
5.5
50
275
723.25
L
Sept -Apr
1
50
5o
131.5
325
B54.75
19
3.73
Wa ram
C
Mar -Sept
5.5
5o
275
1025.75
L
Se t-A r
1
50
5o
186.5
325
1212.26
20
4.61
Wa ram
C
Mar -Set
5.5
50
275
1267.75
L
Sept -Apr
1
50
50
230.5
325
1498.25
21
1.91
Wa ram
C
Mar -Sept
5.5
50
275
525.25
L
Se t-A r
1
50
5o
95.5
325
620.75
22
4,97
Wa ram
C
Mar -Set
5.5
50
275
1366.75
L
Sept -Apr'
1
50
50
248.5
325
1615.26
23
3.58
Wa ram
C
Mar -Set
5.5
50
275
984.5
L
Sept -Apr
1
50
50
179
325
1163.5
24
2.92
Wa ram
C
Mar -Sat
5.5
50
275
803
L
Sept -Apr
1
50
5tl
146
325
949
Sub6-10
0.42
Pocalla
C
Mar -Set
5.0
50
250
105
L
Se t•A r
1
50
50
21
300
126
Sub11-20
6.27
Wa ram
C
Mar -Set
5.5
50
275
1724.25
L
Sept -Apr
1
50
5o
313,5
325
2037,75
Sub2l-241
2.15
Wa ram
C
Mar -Set
5.5
50
275
591.25
L
Sept -Apr
1
50
50
107.5
325
698.75
Sub 25
10.87
Wa ram
F
Se t: A rR
550.0
0.12
15
51
554.37
0
0
51
554.37
Sub 26
9.31
Goldsboro
F
Se t: A rit
700.0
0.12
15
69
1 642.39
0
0
69
642.39
Totals: 141.56 32774.51 6069 38843.51
3(b) of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the craps listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two Inches before drilling for best results.
CROP CODE LEGEND
Crop Code Crop
A Barley
B Hybrid Bermudagrass - Grazed
C Hybrid Bermudagrass - Hay
D Corn - Grain
E Corn - Silage
F Cotton
G Fescue- Grazed
H Fescue - Hay
I Oats
J Rye
K Small Grain - Grazed
L Small Grain - Hay
M Grain Sorghum
N Wheat
O Soybean
P Pine Trees
Lbs N utilized / unit yield
1.6 lbs N 1 bushel
50 lbs N 1 ton
50 lbs N / ton
1.25 lbs N 1 bushel
12 lbs N / ton
0.12 lbs N 1 lbs lint
50 lbs N / ton
50 lbs N I ton
1.3 lbs N / bushel
2.4 lbs N / bushel
50 lbs N / acre
50 lbs N / acre
2.5 lbs N / cwt
2.4 lbs N / bushel
4.0 lbs N / bushel
40 lbs N 1 acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PANlyrlanimal Farm Totaltyr
Farrow to Wean 0.84
Farrow to Feeder 1
1200 Farrow to Finish 4.1 4920
Wean to Feeder 0.072
Feeder to Finish 0.36
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 4920 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 24600 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 82 acreas of land. If you apply the sludge
to cam at a rate of 125 pounds per acre, you will need 196.8 acres of land. Please note that these,
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
*This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. in no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
Freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5of8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract
Hydrant
Type
_Crop
inlhr
t inches
34569
1
Pocalla
C
0.45
1
2
Pocalla
C
0.45
1
3
Pocalla
C
0.45
1
4A
Pocalla
C
0.45
1
6
4B
Pocalla
C
0.45
1
34569
5A
Pocalla
C
0.45
1
6
5B
Pocalla
C
0.45
1
6A
Pocalla
C
0.45
1
6B
Pocalla
C
0.45
1
7A
Pocalla
C
0.45
1
7B
Pocalla
C
0.45
1
8A
Pocalla
C
0.45
1
8B
Pocalla
C
0.45
1
9A
Pocalla
C
0.45
1
9B
Pocalla
C
0.45
1
10A
Pocalla
C
'0.45
1
10B
Pocalla
C
0.45
1
34569
11
Wagram
C
0.6
1
12
Wagram
C
0.6
1
13
Wagram
C
0.6
1
14
Wagram
C
0.6
1
15
Wagram
C
0.6
1
16
Wagram
C
0.6
1
17
Wagram
C
0.6
1
18
Wagram
C
0.6
1
19
Wagram
C
0.6
1
20
Wagram
C
0.6
1
21
Wagram
C
0.6
1
22
Wagram
C
0.6
1
23
Wagram
C
0.6
1
24
Wagram
C
0.6
1
Sub6-10
Pocalla
C
0.45
1
Sub11-20
Wagram
C
0.6
1
Sub21-24
Wagram
C
0.6
1
Sub 25
Wagram
N
0.6
1
Sub 26
Goldsboro
N
0.4
1
6of8

Additional Comments:
Subfield acreage listed on this plan is the balance of total field acres minus
wet acres for this site. This acreage will be claimed when making application
with an aerway machine.
Only change for this
�,plan
t is subfields 25 and 26. It was taken out of Bermuda and
7 of 8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: 5572
Owner: Murphy -Brown, LLC
Manager:
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. Ilwe know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
Itwe understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Murp Brown, LLC
Signature:
Name of Manager (if different from
Signature:
Name of Technical Specialist: Amy E. Roberson_
Affiliation: Murphy -Brown, LLC.
Address: 2822 Hwy 24_West, PO Drawer 856
Warsaw. NC 28398
Signature:
Telephone: [phone]
Date
N
a
8of8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recieving crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients-
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with .the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste small not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2of3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which. will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3 of 3

)<5 -) a
413/2009
,;PR08 � T I UTILIZATION
,,,,.,_ U ENT UTILIZA ON PLAN
Grower(s): -
Farm Name:
Murphy -Brown
Farm 5572
County: Robeson
Farm Capacity:
Farrow to Wean 0
Farrow to Feeder 0
Farrow to Finish 1200
Wean to Feeder
Feeder to Finish 0
Storage Structure: Anaerobic I
Storage Period:
Application Method:
>180 days
Irrigation
.agoon
2822 Hwy 24 West
P.O. Box 856
Warsaw, NC 28398
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown_
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8 RECEIVED 1 DENR / DWQ
AQUIFFR-PRf1TFrTlnN 4FCTION
APR 0 6 ?009

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft3, tons, etc.):
Capacity Type Waste Produced per Animal Total
Farrow to Wean
3212 gal/yr
gal/yr
Farrow to Feeder
4015 gal/yr
gal/yr
1200
Farrow to Finish
10585 gal/yr
12,702,000 gal/yr
Wean to Feeder
223 gallyr
gal/yr
Feeder to Finish
986 gallyr
gaflyr
Total 12,702,000 gallyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs):
Capacity Type Nitrogen Produced per Animal Total
Farrow to Wean
5.4 lbs/yr
lbs/yr
Farrow to Feeder
6.5 lbs/yr
lbs/yr
1200
Farrow to Finish
26 lbs/yr
31,200 lbs/yr
Wean to Feeder
0.48 lbs/yr
lbs/yr
Feeder to Finish
2.3 lbs/yr
ibslyr
Total 31,200 Ibslyr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 137.54
Total N Required 1st Year: 41196.5
Total N Required 2nd Year: 38162.27
Average Annual Nitrogen Requirement of Crops: 39,679.39
Total Nitrogen Produced by Farm: 31,200.00
Nitrogen Balance for Crops: (8,479.39)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2of8

Reception Area Specifications
Tract Field Irrigated Soil 1st Crop Time to 1st Crap 1st Crop Lbs NIAc Lbs N Total Ibs N
Acreacre T e Code Apply Yield Ibs NIUnit Residual fAc Utilized
2nd Crop Time to 2nd Crop 2nd Crop Lbs NiAc Lbs N Total Iba N
Code Apply Yield Ibs NlUnit Residual IAc Utilized
Total
Lbs NfAc
Total Ibs N
Utilized
34569
1
2.57
Pocalla
C
Mar. -Sept.
5.0
50
0
250
642.5
L
SepApril
1
50
0
50
128.5
300
771
2
4.81
Pocalla
C
Mar. -Sept.
&0
50
0
250
1202.5
L
Sop.-Aprill
1
50
0
50
240.5
300
1443
3
5.85
Pocalla
C
Mar. -Sept.
5.0
50
0
250
1462.5
L
Sep. -April
1
50
0
50
292.5
300
1755
4A
0.76
Pocalla
C
Mar. -Sept.
5.0
50
0
250
190
L
Sep. -April
1
50
0
50
38
300
228
4B
5.92
Pocalla
C
Mar, -Se t,
5.0
50
0
250
1480
L
Sep. -April
1
60
0
50
296
300
1776
34569
5A
2.73
Pocalla
C
Mar. -Sept.
5.0
50
0
250
682.5
L
Sep.Aril
1
50
0
50
136.5
300
819
58
4.42
Pocalla
C
Mar. -Sept.
5.0
50
0
250
1105
L
SepAprIl
1
50
0
50
221
300
1326
6A
6.11
Pocalla
C
Mar.-Seet.
5.0
50
0
250
1527.5
L
Se ril
1
50
0
50
305.5
300
1833
6B
3.44
Pocalla
C
Mar. -Sept.
5.0
50
0
250
860
L
Sop.-Aprll
1
50
0
50
172
300
1032
7A
4.76
PaCAlla
C
Mar. -Slept,
510
50
0
250
1190
L
Sep.-Apdl
1
50
0
50
238
300
1428
78
2.93
Pocalla
C
Mar.-Sgt.
5.0
50
0
250
732.5
L
Sep.-Aprll
1
50
0
50
146.5
300
879
8A
4.77
Pocalla
C
Mar. -Sept.
5.0
50
0
250
1192.5
L
Se ,• rll
1
50
0
50
238.5
300
1431
8B
3.85
Pocalla
C
Mar. -Sept.
5.0
50
0
250
962.5
L
Sev.-Aixill
1
50
0
50
192.5
300
1155
9A
4.47
Pocalla
C
Mar. -Se 1.
5.0
50
0
250
1 1117.5
L 1
Sep, -April
1
1 50
0
50
223.5
300
1341
9B
2.37
Pocalla
C
Mar. -Sept,
5.0
50
0
250
592.5
L
Sep. -April
11
50
0
1 50
118.5
300
711
10A
2.96
Pocalle
C
Mar.-Sgt.
50
50
0
250
740
L
Sep. -April
1
50
0
50
148
300
888
10B
0.93
Pocalle
C
Mar, -Sept.
5.0
50
0
250
232.5
L
Se .•A dl
1
50
0
50
46.5
300
279
34569
11
1.9
Wa rem
C
Mar. -Sept.
5.5
50
0
275
522.5
L
Se .•A OI
1
50
0
50
95
325
617.5
12
2.31
Wa rem
C
Mar,Se t.
5.5
50
0
275
635.25
L
Sep.-APHI
1
50
0
50
115.5 1
325
750.75
13
2.29
Wa ram
C
Mar. -Sept.
5.5
50
0
275
629.75
L
Se I
1
50
0
50
114.5
325
744.25
14
2.9
Wa ram
C
Mar. -Sept.
5.5
50
0
275
797.5
L
SeD.-ADHII
1
50
0
50
145
325
942,5
15
2.57
We ram
C
Mar. -Sept
5.5
50
0
275
706.75
L
Sep, -April
1
50
0
50
128.5
325
835.25
16
2.31
Wa ram
C
Mar: Se t.
5.5
50
0
275
635.25
L
Se rll
1
50
0
1 50
115.5
325
750.75
17
2.74
We ram
C
Mar: Se t.
565
50
0
275
753.5
L
Sep. -April
1
50
0
50
137
325
890.5
16
3.35
Wa ram
C
Mar. -Sept
5.5
50
0
275
921.25
L
Se .-A rll
1
50
0
50
167.5
325
1088.75
19
3.64
Wa ram
C
Mar. -Sept.
5.5
50
0
275
1001
L
Se : A dl
1
50
0
50
182
325
1183
20
1.9
Wa rem
C
Mar. -Sept,
515
50
0
275
1 522.5
L
Sep. -April
1
50
0
50
95
325
617.5
21
2.7
W e ram
C
Mar. -Sept.
5.5
50
0
275
742.5
L
Sep.-Aprill
1
50
0
50
135
325
877.5
22
4.4
W a ram
C
Mar. -Sept.
5.5
50
0
275
1210
L
Sep, 1
t
50
0
50
220
325
1430
23
3.49
Wa ram
C
Mar. -Sept.
5.5
50
0
275
959.75
L
Soo.-Avrill
1
50
0
50
174.5
325
1134.25
24
1.63
Wactram
C
Mar. -Sept.
5.5
50
0
275
448,25
L
Sep.-Aprill
1
50
0
50
81.5
325
529.75
subl
6.27
Pocalla
C
Mar.•Se t.
510
50
0
250
1567.5
L
Sep.-Aprill
1
50
0
50
313.5
300
1881
sub2
7.87
Wa ram
C
Mar.-Sgt.
5.5
50
0
275
2164.25
L
Sep. -April
1
50
0
50
393.5
325
2557.75
sub3
2.53
Wagram
C
I Mar. -Sept.
5,5
50
0
275
695.75
L
Se .-A rtl
1
50
0
50
126.5
325
822.25
sub4
8.56
Goldsboro
0
Jun -Set
42.0
4
0
168
1438.08
N
Sep. -April
60
2.4
15
129
1104.24
297
2542.32
sub5
10.53
Wa ram
0
Jun -Sot
25.0
4
0
100
1053
N
Se I
40
2A
15
81
052.93
181
1906.93
7otafs: 137.54 33316.63 7879.67 41196.3
3(a) of 8

Reception Area Specifications
Tract Field irrigated Soil 1st Crop Time to 1st Crop 1st Crop Lbs NIAc Lbs N Total Ibs N
Acres e Type Code Apply Yield Ibs NlUnit Residual fAc Utilized
2nd Crop Time to 2nd Crop 2nd Crop Lbs N Ac Lbs N Total Ibs N
Code Apply Yield Ibs NlUnit Residual fAc Utilized
Total
Lbs NlAc
Total Ibs N
Utilized
34569
1
2.57
Pocalla
C
Mar. -Sept.
5.0
50
0
250
642.5
L
SoR.-April
1
50
0
50
128.5
300
771
2
4.81
Pocalta
C
Mar, -Sept,
5XIm
50
0
250
1202.5
L
Sep.-Apdl
1
50
0
s0
240.5
300
1443
3
535
Pocalla
C
Mar.-Sopt.
6.0
5o
0
250
1462.5
L
Sep,-Apdl
1
50
0
50
292.5
300
1755
4A
0.76
Pocalla
C
Mar, -Se t,
590
5o
0
250
190
L
Sep.-Apdl
1
50
0
50
38
300
228
48
5,92
Pocalta
C
Mar.So t.
5.0
5o
0
250
1480
L
Sep. -April
1
50
0
50
296
300
1776
34569
5A
2.73
Pocalla
C
Mar.•Se t.
5.0
50
0
250
682.5
L
ril
1 j
50
0 1
50
136.5
300
819
SB
4.42
Pocalla
C
Mar,Sept. t.
5.0 1
50
0
250
1105
L
Sep. -April
I 50
0
50
221
300
1326
6A
6,11
Pocalla
C
Mar. -Sept.
5.0
50
0
250 1
1527.5
L
Sep.-APdl
1 1
50
0
50
305.5
300
1833
6B
3.44
Pocalla
C
Mar. -Sept.
5.0
50
0
250
860
L
Se .•A dl
1
5o
0
50
172
300
1032
7A
4.76
Pocalla
C
Mar. -So t.
5.0
50
0
250
1190
L
Sep, -April
1
50
0
50
238
300
1428
7B
2.93
Pocalla
C
Mar.-Sgt.
5,0
50
0
250
732.5
L
Sep.-Aprll
1
50
0
50
146.5
300
879
8A
4.77
PoCelle
C
Mar.•Sa t.
5A
60
0
250
1192.5
L
S ,• dl
1
50
0
50
238.5
300
1431
BB
3.85
Pocalla
C
Mar. -Sept,
5.0
50
0
250
962.5
L
Se ,-A dl
1
50
0
50
192.5
300
1155
9A
4.47
Pocalla
C
Mar. -Sept.
510
50
0
250
1117.5
L
Sa .•A dl
1
50
0
50
223.5
300
1341
98
2.37
Pocalla
C
Mar. -Sept.
5,0 1
66
0 1
250
592.5
L
Se .-A ril
1
50
0
50
118.5
300
711
10A
2.96
Pocalla
C
Mar: Se t.
5.0
50
0
250
740
L
Se : A di 1
1
50
0
50
148
300
888
10B
0.93
Pocalle
C
Mar. -Sept.
6.0
50
0
250
232.5
L
Se .-A ril
1
5o
0
50
46.5
300
279
34569
11
1.9
Wa rem
C
Mar. -Sept
5.5
so
0
275
522.5
L
Se .-A ril
1
50
0
50
95
325
617.5
12
2.31
Wa ram
C
Mar. -Sept.
5.5
50
0
275
635.25
L
Se .-A ill
1
50
0
50
1155
325
750.75
13
2.29
Wa rem
C
Mar. -Sept.
5.5
50
0
275
629.75
1 L
Se .-A r11
1
50
0
50
114.5
325
744.25
14
2.9
Wa ram
C
Mar. -Sept.
5.5
50
0
275
797.5
L
Sa - di
1
50
0
50
145
325
942.5
15
2.57
Wa rom
I C
Mar. -Sept.
5,5
50
0
275
706.75
L
Se : 1
1
50
0
50
128.5
325
835.25
16
2.31
Wa ram
C
Mar. -Sept.
5,5
50
0
1 275
635.25
L
Se .- 1
1
50
0
50
115.5
325
750.75
17
2,74
Wa rem
C
Mar. -Sept.
5.5
s0
0
275
753.5
L
Set).-ADHII
1
50
0
50
137
325
890.5
18
3.35
Wa rom
C
Mar.-Sgt.
5.5
50
0
275
921.25
L
SepApdl
1
50
0
50
1 167.5
325
1088,75
19
3.64
Wa rem
C
Mar. -Se t.
5.5
5o
0
275
1001
L
Sep.-Apdl
1
50
0
50
182
325
1183
20
1.9
aremC
Mar.Se t.
6.5
50
0
275
522.5
L
Se ril
1
50
0
50
95
325
617.5
21
2.7
rw�aarvm
C
Mar.Se t.
5.5
50
0
275
742.5
L
Se rll
1
50
0
50
135
325
877.5
22
4.4
C
I Mar,Sa t.
5.6
50
0
275
1210
1 L
Se .-A dl
1
50
0
50
220
325
1430
23
3,49
Wa rem
C
Mar. -Se t.
5.5
50
0
275
959.75
L
Se it
1
50
0
50
174.5
325
1134.25
24
1.63
Wa ram
C
Mar. -Se t.
5.5
50
1 0
275
448,25
L
I Sao. -April
1
50
0
50
81.5
325
529,75
subl
6,27
Pocalla
C
Mar. -Sept.
5.0
50
0
250
1567.5
L
Sep.-Aprill
1
50
0
50
313.5
1 300
1881
sub2
7,87
Wa ram
C
Mar. -Sept,
5.5
50
0
275
2164.25
L
Se .-A ril
1
50
0
50
3915
325
2557.75
sub3
2.53
Wa ram
C
Mar. -Sept.
5.5
50
0
275
695,75
L
Sep. -April
1
50
0
50
126.5
325
822.25
sub4
8,56
Goldsboro
F
Apr-Aupust
700.0
0.12
84
719.04
0
0
84
719.04
subs
10.53
Wa ram
F
Apr -August
550.0
0.12
66
694,98
0
0
66
694.98
Totaly 137.54 32239.77 5922.5 38162.27
3(b) of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches_ Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code Crop
A Barley
B Hybrid Bermudagrass - Grazed
C Hybrid Bermudagrass - Hay
D Corn - Grain
E Corn - Silage
F Cotton
G Fescue- Grazed
H Fescue - Hay
I Oats
J Rye
K Small Grain - Grazed
L Small Grain - Hay
M Grain Sorghum
N Wheat
O Soybean
P Pine Trees
Lbs N utilized 1 unit yield
1.6 lbs N 1 bushel
50 lbs N 1 ton
50 lbs N 1 ton
1.25 lbs N 1 bushel
12 Ibs N / ton
0.12 lbs N 1 lbs lint
50 lbs N 1 ton
50 lbs N 1 ton
1.3 lbs N / bushel
2.4 lbs N / bushel
50 lbs N 1 acre
50 lbs N 1 acre
2.5 lbs N / cwt
2.4 lbs N / bushel
4.0 lbs N 1 bushel
40 lbs N 1 acre 1 yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications
PANlydanimal
Farm Total/
0 Farrow to Wean
0.84
0
0 Farrow to Feeder
1
0
1200 Farrow to Finish
4.1
4920
Wean to Feeder
0.072
0 Feeder to Finish
0.36
0
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 4920 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 24600 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 82 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 196.8 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
*This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for > 180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5of8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract
Hydrant
Type
Crop
inlhr
* inches
34569
1�
Pocalla
C
0.45
1
2
Pocalla
C
0.45
1
3
Pocalla
C
0.45
1
4A
Pocalla
C
0.45
1
4B
Pocalla
C
0.45
1
34569
5A
Pocalla
C
0.45
1
5B
Pocalla
C
0.45
1
6A
Pocalla
C
0.45
1
6B
Pocalla
C
0.45
1
7A
Pocalla
C
0.45
1
7B
Pocalla
C
0.45
1
8A
Pocalla
C
0.45
1
8B
Pocalla
C
0.45
1
9A
Pocalla
C
0.45
1
9B
Pocalla
C
0.45
1
10A
Pocalla
C
0.45
1
10B
Pocalla
C
0.45
1
34569
11
Wagram
C
0.6
1
12
Wagram
C
0.6
1
13
Wagrarn
C
0.6
1
14
Wagram
C
0.6
1
15
Wagram
C
0.6
1
16
Wagram
C
0.6
1
17
Wagram
C
0.6
1
18
Wagram
C
0.6
1
19
Wagram
C
0.6
1
20
Wagram
C
0.6
1
21
Wagram
C
0.6
1
22
Wagram
C
0.6
1
23
Wagram
C
0.6
1
24
Wagram
C
0.6
1
subl
Pocalla
C
0.45
1
sub2
Wagram
C
0.6
1
sub3
Wagram
C
0.6
1
sub4
Goldsboro
O
0.4
1
sub5
Wagram
O
0.6
1
6 of 8

Additional Comments:
Subfields indicate areas that will be applied to using an aerway applicator.
f'
Pulls contained in each subfield are as follows:
Sub1 - Pulls 1-513
Sub2 - Pulls 6A-20
Sub3 - Pulls 21-24
Sub4 - Field 2 and Subs - Field 1
All fields must be cut for hay.
7 of 8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: Farm 5572
Owner: Murphy -Brown
Manager:
OwnedManager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff_
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Murphy -Brown
Signature:
Name of Manager (if different from owner):
Signature:
Name of Technical Specialist: Amy E. Roberson
Affiliation: Murphy -Brown, LLC.
Address: 2822 Hwy 24 West, PO Drawer 856
Warsaw. NC 28398
Signature:
Telephone: [phone]
Date
Date
Date
8 of 8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recievinq crop type, or available land-
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth, The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds_
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3 of 3

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Coleen H. Sullins, Director
Division of Water Quality
July 1, 2007
Murphy -Brown, LLC d JUN 2 7 2l
7572
PO Box 856 -
Warsaw, NC 28398 -
Subject: Certificate of Coverage No. AWS780012
7572
Animal Waste Management System
Robeson County
Dear Murphy -Brown, LLC:
In accordance with your application received on 11-Jun-07, we are hereby forwarding to you this
Certificate of Coverage (COC) issued to Murphy -Brown, LLC, authorizing the operation of the subject
animal waste management system in accordance with General Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for the 7572, located in Robeson County, with an animal capacity of no greater than the
following swine annual averages:
Wean to Finish: 0 Feeder to Finish: 0 Boar/Stud: 0
Wean to Feeder: 0 Farrow to Wean: 0 Gilts: 0
Farrow to Finish: 1200 Farrow to Feeder: 0
If this is a Farrow to Wean or Farrow to Feeder operation, there may also be one boar for each 15 sows.
Where boars are unneccessary, they may be replaced by an equivalent number of sows. Any of the sows
may be replaced by gilts at a rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009 and replaces the NPDES
COC issued to this facility with an expiration date of July 1, 2007. You are required to continue
conducting annual surveys of sludge accumulation in all lagoons at your facility; the one-year extension
in Condition IR.19 does not apply.
Pursuant to this COC, you are authorized and required to operate the system in conformity with the
conditions and limitations as specified in the General Permit, the facility's CAWMP, and this COC. An
adequate system for collecting and maintaining the required monitoring data and operational information
must be established for this facility. Any increase in waste production greater than the certified design
capacity or increase in number of animals authorized by this COC (as provided above) will require a
modification to the CAWMP and this COC and must be completed prior to actual increase in either
wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Enclosed for your convenience is
a package containing the new and revised forms used for record keeping and reporting. Please pay
careful attention to the record keeping and monitoring conditions in this permit.
Aquifer Protection Section 1636 Mail Service Center
Internet: www.ncwatergualitv.o!X Location: 2728 Capital Boulevard
An Equal OgxrtunitylAthnnative Action Employer— 50% Recydedl10% Post Consumer Paper
1M Carolina
Amura!!y
Raleigh, NC 27699-1636 Telephone: [phone]
Raleigh, NC 27604 Fax 1: [phone]
Fax 2: [phone]
Customer Service: [phone]

If your Waste Utilization Plan has been developed based on site -specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 02T .01 I I(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100-foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Per 15A NCAC 02T .1306, any containment basin, such as a lagoon or waste storage structure, shall
continue to be subject to the conditions and requirements of the facility's permit until closed to NRCS
standards and the permit is rescinded by the Division.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Aquifer Protection staff may be reached at 910-433-3300. If you need additional information concerning
this COC or the General Permit, please contact the Animal Feeding Operations Unit staff at (919) 733-
3221.
Sincerely,
for Coleen H. Sullins
Enclosures (General Permit AWG100000, Record Keeping and Reporting Package)
cc: (Certificate of Coverage only for all cc's)
Robeson County Health Department
Robeson County Soil and Water Conservation District
Fayetteville Regional Office, Aquifer Protection Section
AFO Unit Central Files
Permit File AWS780012

Michael F. Easley, Governor
William G. Ross 3r., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E. Director
Division of Water Quality
December 1, 2006
CERTIFIED MAIL
RETURN RECEIPT REOUESTED I '
Carroll's Foods Inc
7572 ir.-W
PO Drawer 856
Warsaw, NC 2839$
Subject: Application for Renewal of Coverage for Expiring NPDES General Permit
Dear Permittee:
Your facility is currently approved for operation under one of the Animal Waste Operation NPDES General Permits, which expire on
July 1, 2007. Due to changes in federal rules, facilities that do not discharge nor propose to discharge may choose whether or not to
retain coverage under an NPDES General Permit. Copies of the draft animal waste operation NPDES general permits and the State
Non -Discharge General Permits are available at http://h2o.enr.state.nc.us/a s/afou/downloads.htm or by writing or calling:
NCDENR — DWQ Animal Feeding Operations Unit
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure your continued coverage under one of these two types of general permits, you must submit an application for permit
coverage to the Division. Enclosed You will find a `Request for Certificate of Coverage Facility Currently Covered by an Expiring
NPDES General Permit.' The application form must be completed and returned by January 2, 2007. Please note, you must include
two (2) copies of your most recent Waste Utilization Plan with the application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to S25,000 per day.
If you have any questions about the draft general permits, the enclosed application, or any related matter please feel free to contact the
Animal Feeding Operations Unit staff at 919-733-3221.
Sincerely,
Ted L. Bush, Jr., Chief
Aquifer Protection Section
Enclosures
cc (w/o enclosures): Robeson County Soil and Water Conservation District
Fayetteville Regional Office, Aquifer Protection Section
AFO Unit Central Files - 780012
Carroll's Foods Inc
Aquifer Protection Section 1636 Mail Service Center
Internet: www.ncwatemuality.org location: 2728 Capital Boulevard
An Equal Opportunity/Affirmative Action Employer— 50% Recydedl10% Post Consumer Paper
Raleigh, NC 27699-1636 Telephone:
Raleigh, NC 27604 Fax 1:
Fax 2:
Customer Service:
140oAhCarolina
(919) �11?atul'rt!!1✓
[phone]
[phone]
[phone]

Murphy -Brown, LLC
Grower(s):
Farm Name:
1 /9/2006
NUTRIENT UTILIZATION PLAN
Murphy -Brown
Farm 5572 (159a)
County: Robeson
Farm Capacity:
Farrow to Wean 0
Farrow to feeder 0
Farrow to Finish 1200
Wean to Feeder
Feeder to Finish 0
Storage Structure:
Storage Period:
Application Method:
Anaerobic Lagoon
>180 days
Irrigation
2622 Hwy 24 West
. P.O. Box 856
Warsaw, NC 28398
RFCF�VFQ
MAY 0 8 2006
OERR-FAYEi LfEREGlQN4LOFFICE
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ff, tons, etc.):
Capacity Type Waste Produced per Animal Total
Farrow to Wean
3212 gal/yr
gal/yr
Farrow to Feeder
4015 gal/yr
gal/yr
1200
Farrow to Finish
10585 gal/yr
12,702,000 gal/yr
Wean to Feeder
223 gal/yr
gal/yr
Feeder to Finish
985 gal/yr
gal/yr
Total 12,702,000 gal/yr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs):
Ca aci Type Nitrogen Produced per Animal Total
Farrow to Wean
5.4 lbs/yr
lbs/yr
Farrow to Feeder
6.5 lbs/yr
lbs/yr
1200i
Farrow to Finish
26 lbs/yr
31,200 lbs/yr
Wean to Feeder
0.48 lbs/yr
lbs/yr
Feeder to Finish
2.3 lbs/yr
lbs/yr
Total 31,200 Ibslyr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 118.45
Total N Required 1st Year: 36748.25
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops: 36,743.25
Total Nitrogen Produced by Farm: 31,200.00
Nitrogen Balance for Crops: (5,548.25)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2of8

Reception Area Specifications
Tract Field Irrigated Soil 1st Crop Time to 1st Crop tat Crop Lbs WAc Lbs N TOM tbs N
Acroa e Type Code Apply Yield lbs WUnit Residual !Ac Utllized
2nd Crop Time to 2nd Crop 2nd Crop Lbs NlAc Lbs N Total lbs N
Code Apply Yield lbs NlUnit Residual lAc Utilized
Total
Lbs NlAc
Total Ibs N
Utilized
34569
1
2.57
Pocalla
C
Mar. -Sept,
5,0
50
0
250
642.5
L
Sep.-Apdl
1
50
0
50
128.5
300
771
2
4.81
Pocalla
C
Mar. -Sept.
5.0
50
0
250
1202.5
L
Sep.-ApHl
1
50
0
50
240.5
300
1443
3
5.85
Pocalla
C
Mar.-SePt.
5.0
50
0
250
1462.5
L
Se ,- dl
1
50
0
50
292.5
300
1755
4A
0.76
Pocalla
C
Mar. -Sep(.
&0
50
0
250
190
L
Se ril
1
50
0
50
38
300
228
6
48
5.92
Pocalla
C
Mar. -Sept.
5,0
50
0
250
1480
L
SO .: dl
1
50
0
50
296
300
1776
34569
5A
2.73
Pocalla
C
Mar. -Sept.
5.0
50
0
250
682.6
L
Sap. -April
1
50 1
0
50
136.5
300
819
6
5B
4.42
Pocalla
C
Mar. -Sep(,
5.0
50
0
250
1105
L
Sep, -April
1
50
0
50
221
300
1326
6A
6.11
Pocalla
C
Mar, -Sept.
&0
50
0
250
1527.5
L
-Sep.-April
1
50
0
50
305.5
300
1833
613
3.44
Pocalla
C
Mar. -Sept.
5.0
50 i
0
250
660
L
Sep.-Apnl
1
50
0
50
172
300
1032
7A
4.76
Pocalla
C
Mar. -Sept.
5.0
50
0
250
1190
L
Sep. -April
1
50
0
50
238
300
1428
7B
2.93
Pocalla
C
Mar -Sept.
5.0
50
0
250
732.5
L
Se di
1
50
0
50
146,5
300
679
8A
4.77
Pocalla
C
Mar. -Sept.
5.0
50
0
250
1192.5
L
Sam -April
1
50
0
50
238.5
300
1431
8B
3.85
Pocalla
C
Mar. -Sep(.
5.0
50
0
250
962.5
L
Sa ,- I
1
50
0
50
192.5
300
1155
9A
4,47
Pocalle
C
Mar. -Se
5.0
50
0
250
1117.5
L
Se , dl
1
50
0
50
223.5
300
1341
98
2.37
Pocalla
C
Mar. -Sept.
5,0
50
0
250
592.6
L
Se dl
1
50
0
50
118.5
300
711
10A
2.96
Pocalla
C
Mar. -Sept.
5.0
50
0
250
740
L
Se dl
1
50
0
50
148
300
888
10B
0.93
Pocalla
C
Mar. -Sept.
5.0
50
0
250
232.5
L
Se .-A ril
1
50
0
50
46,5
300
279
34569
11
1,9
Wa ram
C
Mar. -Sept.
5.5
50
0
275
522.5
L
Se rll
1
50
0
50
95
325
617.5
12
2.31
Wa ram
C
Mar.-SoDt.
5.5
50
0
275
635.25
L
Sem-April
1
50
0
50
115.5
325
750,75
13
2.29
Wa ram
I C
Mar. -Sept.
5.5
50
0
275
629,76
L
Sep.,Apdl
1
50
0
50
114.6
325
744.25
14
2.9
Wa ram
C
Mar. -Sept.
5.5
50
0
275
797.5
L
Se l
1
50
0
50
145
325
942.5
15
2.57
We ram
C
Mar. -Se
6.5
50
0
275
706.75
L
Se I
1
50
0
50
128.5
325
835.25
16
2.31
Wagram
C
Mar. -Sept.
5.5
50
0
275
635.25
L
Se rll
1
50
0
50
115.5
325
750.75
17
2.74
We ram
C
Mar. -Sept.
5.5
50
0
275
753.5
L
Se dt
1
50
0
50
137
325
890.5
18
3.35
Wa ram
C
Mar. -Sept.
5.5
50
0
275
921,25
L
Sep. -April
1
50
0
50
167,5
325
1088.75
19
3.64
Wa ram
C
Mar. -Sept.
5,5
50
0
275
1001
L
Se ,-A dl
1
50
0
50
182
325
1183
20
1,9
Wa ram
C
Mar. -Sept.
5.5
50
0
275
522.5
L
Se .-A ril
1
50
0
50
95
325
617.5
21
2.7
Wa ram
C
Mar. -Sept.
5.5
50
0
275
742.5
L
Sep.-ApH1
1
50
0
50
135
325
877.5
22
4,4
Wa ram
C
Mar. -Sept.
5.5
50
0
275
1210
L
Se dl
1
50
0
50
220
325
1430
23
3.49
Wa ram
C
Mar. -Sept.
5.5
50
0
275
959.75
L
Se dl
1
50
0
50
174,5
1 325
1134.25
24
1.63
Wagram
C
Mar. -Sept,
5.5
50
0
275
448.25
L
So dI
1
50
0
50
81,5
325
529.75
subl
6.27
Pocalla
C
Mar. -Sept.
5.0
50
0
250
1567.5
L
Se dl
1
50
0
50
313,5
300
1881
sub2
7,87
Wa ram
C
Mar. Se .
5.5
50
0
275
2164.25
1 L
Se dl
1
50
0
50
393.5
325
2557.75
sub3
2,53
Wa ram
C
Mar. -Sept.
5.5
50
0
275
695.75
L
$op.-Apr1I
1
1 50-
0
50
126.5
325
822.25
Totals: 448.45 30825.75 5922.5 36748.25
3(a) of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially We in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized / unit yield
A
Barley
1.6 lbs N / bushel
B
Hybrid Bermudagrass - Grazed
50 lbs N /ton
C
Hybrid Bermudagrass - Hay
50 lbs N /ton
D
Corn - Grain
1.25 lbs N / bushel
E
Corn - Silage
12 lbs N / ton
F
Cotton
0.12 lbs N I lbs lint
G
Fescue - Grazed
50 lbs N I ton
H
Fescue - Hay
50 lbs: N 1 ton
1
Oats
1.3 lbs N / bushel
,f
Rye
2.4 lbs N / bushel
K
Small Grain - Grazed
50 lbs N 1 acre
L
Small Grain - Hay
50 lbs N / acre
M
Grain Sorghum
2.5 lbs N / cwt
N
Wheat
2.4 lbs N / bushel
O
Soybean
4.0 lbs N / bushel
P
Pine Trees
40 lbs N / acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4 of 8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications
PAN/ /animal
Farm Total/
0 Farrow to Wean
0.84
0
0 Farrow to Feeder
1
0
1200 Farrow to Finish
4.1
4920
Wean to Feeder
0.072
0 Feeder to Finish
0.36
0
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 4920 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 24600 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 82 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 196.8 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
*This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 8

Application Rate Guide
The fallowing is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract
Hydrant
Tye
Crop
inlhr
* inches
34569
1
Pocalla
C
0.45
1
2
Pocalla
C
0.45
1
3
Pocalla
C
0.45
1
4A
Pocalla
C
0,45
1
6
4B
Pocalla
C
0.45
1
34569
5A
Pocalla
C
0.45
1
6
5B
Pocalla
C
0.45
1
6A
Pocalla
C
0.45
1
6B
Pocalla
C
0.45
1
7A
Pocalla
C
0.45
1
7B
Pocalla
C
0.45
1
BA
Pocalla
C
0.45
1
8B
Pocalla
C
0.45
1
9A
Pocalla
C
0.45
1
9B
Pocalla
C
0.45
1
10A
Pocalla
C
0.45
1
10B
Pocalla
C
0.45
1
34569
11
Wagram
C
0.6
1
12
Wagram -
C
0.6
1
13
Wagram
C
0.6
1
14
Wagram
C
0.6
1
15
Wagram
C
0.6
1
16
Wagram
C
0.6
1
17
Wagram
C
0.6
1
18
Wagram
C
0.6
1
19
Wagram
C
0.6
1
20
Wagram
C
0.6
1
21
Wagram
C
0.6
1
22
Wagram
C
0.6
1
23
Wagram
C
0.6
1
24
Wagram
C
0.6
1
subl
Pocalla
C
0.45
1
sub2
Wagram
C
0.6
1
sub3
Wagram
C
0.6
1
6of8

Additional Comments.
Subfields indicate areas that will be applied to using an aerway applicator.
Pulls contained in each subfield are as follows:
Sub1 - Pulls 1-56
Sub2 - Pulls 6A-20
Sub3 - Pulls 21-24
All fields must be cut for hay.
7of8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: Farm 5572
Owner: Murphy -Brown
Manager:
Owner/Manager Agreement:
Itwe understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. Uwe know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
l/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. i also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Murphy -Brown
Signature: �/ �G6 }�7
1 !! Date
Name nager (if different from owner): U)0'0 A No{djn
Signature:
Name of Technical Specialist: Kraig Westerbeek
Affiliation: Murphy -Brown, LLC.
Address: 2822 Hwy 24 West, PO Drawer 856
Wnrcnw Nr_ 9R3QR
Signature:
Q006
Date
:0J
8of8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recieving crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
G When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Wastelnutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2of3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3 of 3

Sheetl
IRRIGATION SYSTEM DESIGN PARAMETERS
Landowner/Operator Name: Murphy -Brown Farm 5671
Address: PO Box 856
Warsaw, NC 28398
Telephone: [phone]
Table 1 - Field Specifications
Approximate
Maximum
Useable Size
Field of Field
Number (acres)
Soil Type Slope % Crop(s)
County: Robeson
Date: 1 /9/2005
Maximum
Maximum
Application
Application
per Irrigation
Rate
Cycle
(inthr)
(inches) Comments

Sheet2
TABLE 2 - Travelling Irrigation Gun Settings
Make, Model and Type of Equipment: 3" and 3.7" Travellers; Nelson 150 guns
Travel Application TRAVEL LANE Wetted Nozzle Operating Operating
Speed Rate Effective Effective Diameter Diameter Pressure Pressure Arc
Hvdrant No. (ft1min) (in/hr.) Width(ft.) Length(ft) (feet) (Inches) at Gun(psi) at reel(psi) Pattern Comments - Acres per pull
1
3.01
0.51
262
215
284
1.18
60
100
330
2.57
2
3.01
0.51
240
648
284
1.18
60
100
330
4.81
3
3.01
0.51
262
818
284
1.18
60
100
330
5.85
4A
6.57
0.84
110
181
284
1.18
60
100
180
0.76
4B
3.28
0.51
252
905
284
1.18
60
100
330
5.92
5A
3.28
0.51
252
355
284
1.18
60
100
330
2.73
56
3.94
0.69
175
1000
284
1.18
60
100
220
4.42
6A
1 3.01
0.51
262
899
284
1.18
60
100
330
6.11
66
3.01
0.51
262
455
284
1.18
60
100
330
3.44
7A
3.01
0.51
240
741
2B4
1.18
60
100
330
4.76
7B
3.01
0.51
240
408
284
1.18
60
100
330
2.93
8A
3.01
0.51
240
742
284
1.18
60
100
330
4.77
8B
3.01
0.51
240
575
284
1.18
60
100
330
3.85
9A
3.01
0.51
240
750
284
1.18
60
100
330
4.47
96
3.01
0.51
240
306
284
1.18
60
100
330
2.37
10A
3.61
0.51
210
527
284
1.18
60
100
220
2.96
10B
3.61
0.69
120
222
284
1.18
60
100
220
0.93
11
3.01
0.51
262
103
284
1.18
60
100
330
1.90
12
3.01
0.51
240
195
284
1.18
60
100
330
2.31
13
3.01
0.51
240
190
284
1.18
60
100
330
2.29
14
3.01
0.51
240
301
2B4
1.18
60
100
330
2.90
15
3.01
0.51
240
241
284
1.18
60
100
330
2.57
16
3.01
0.51
240
195
284
1.18
60
100
330
2.31
17
3.01
0.51
240
272
284
1.18
60
100
330
2.74
18
3.01
0.51
240
383
284
1.18
60
100
330
3.35
19
3.01
0.51
262
399
284
1.18
60
100
330
3.64
20
3.01
0.51
284
95
284
1.18
60
100
330
1.9
21
6.57
0.84
120
748
284
1.18
60
100
180
2.7
22
3.28
0.511
220
638
284
1.18
60
100
330
4.4
23
3.28
0.51
220
457
284
1.18
60
100
330
3.49
24
1 3.941
F691
186
2451
284
1 1.18
1 60
1 100
220
1.63

Sheet?
CALCULATIONS
Sprinkler Specifications
Sprinkler Type: Nelson 150
Nozzle Size:
1.18 inches
Sprinkler Pressure:
60 psi
Flowrate(GPM):
225 gpm
Wetted Diameter:
284 feet *90% of manufacturer's charts
Lane Spacings
Desired Spacing (%):
70 %
Design Spacing(feet):
198.8 *PVC irrigation pipe normally comes in 20' pieces,
so round to the nearest multiple of 20.
Actual Spacing (feet):
240 feet
Actual Spacing (%):
85 %
ApiRlication Rate
Application Date =(96.3xFlowrateu(3.1415x(.9xradius)squared)
Design App. Rate =
0.42 inthr
300 degree arc =
0.51 inlhr
220 degree arc =
0.69 inlhr
180 degree arc =
0.84 inthr
Traveller S eed
Travel speed = 1.605 x Flowrate 1 Desired application amount x Lane Spacing
Desired app. (in.) =
0.5 inches
300 degree arc =
3.01 ft1min
220 degree arc =
3.61 ft/min
180 degree arc =
6.02 ftlmin
Mainline Velocity
Velocity = .408 x Flowrate 1 pipe diameter squared feettsec.**
**For buried pipelines, velocity should be below 5 feet per second
Pipe size:
inches
Velocity=
#DIVI01 ftlsec.
Page 1

Sheet?
Maximum Mainline Friction Loss
Most distant hydrant:
Total distance: feet
Friction Loss is figured using HazenMiliiam's Equation
Friction Loss= #DIVIO! feet1100 feet
Max. Mainline Loss = #D1V101 feet or #DIV101 psi
Total Dynamic Head
Sprinkler Pressure: 60 psi
Loss through traveller: psi
Elevation head: psi
Mainline loss: #DIVIO! psi
Suction head and lift: psi
5% fitting foss: #DIV101 psi
TOTAL(TDH) _ #D1V10! psi or #DIV101 feet
Horsepower Required
Horsepower = Flowrate x TDH(feet)139601 Pump effeciency
Pump Description:
Pump Efficiency: °%
Horsepower Required: #DIVIO! Hp
Thrust Blocking
Thrust Block Area = Thrust I Soil Bearing Strength
Thrust: feet
Soil Bearing Strength: feet
End Cap: #DIVIO! ft2
90 degree elbow: #D1V10! ft2
Tee: #DIVIO! f.2
45 degree elbow: #DIV101 ft2
Pipe Pressure Rating Check
Pressure Rating of Pipe to be Used: psi
Max. Pressure on system when running: #DIVIO! psi
70% of Pressure Rating: 0 psi
If Max. Pressure on system is less than 70% of Pressure Rating, OK
Net Positive Suction Head Check
Page 2

Sheet7
NPSHA:
NPSHR: 'from pump curve
If NPSHA>NPSHR OK
Page 3

Sheet7
CALCULATIONS
Sprinkler Specifications
Sprinkler Type: Nelson
150
Nozzle Size:
1.18 inches
Sprinkler Pressure:
60 psi
Flowrate(GPM):
225 gpm
Wetted Diameter:
284 feet "90% of manufacturer's charts
Lane Snacinas
Desired Spacing (%):
70 %
Design Spacing(feet):
198.8 `PVC irrigation pipe normally comes in 20' pieces,
so round to the nearest multiple of 20.
Actual Spacing (feet):
220 feet
Actual Spacing {%}:
77 %
Application Rate
Application Rate =(96.3xFlowrate)1(3.1415x(.9xradius)squared)
Design App. Rate =
0.42 in/hr
300 degree arc =
0.51 in/hr
220 degree arc =
0.69 inthr
180 degree arc =
0.84 in/hr
Traveller Speed
Travel speed = 1.605 x Flowrate
/ Desired application amount x Lane Spacing
Desired app. (in.) =
0.5 inches
300 degree arc =
3.28 ft/min
220 degree arc =
3.94 ft/min
180 degree arc =
6.57 ft/min
Mainline Velocity
Velocity = .408 x Flowrate I pipe diameter squared feet/sec.;`
"*For buried pipelines, velocity should be below 5 feet per second
Pipe size:
inches
Velocity=
#DIV/01 ft/sec.
Page 1

Sheet7
Maximum Mainline Friction Loss
Most distant hydrant:
Total distance: feet
Friction Loss is figured using Hazen/William's Equation
Friction Loss= #DIVIO! feet1100 feet
Max. Mainline Loss = #DIVIO1 feet or #DIVIO! psi
Total Dynamic Head
Sprinkler Pressure: 60 psi
Loss through traveller: psi
Elevation head: psi
Mainline loss: #DIVIOI psi
Suction head and lift: psi
5% fitting loss: #DIVIO! psi
TOTAL(TDH) _ #DIVIOI psi or #DIVIO! feet
Horsepower Required
Horsepower = Flowrate x TDH(feet) 13960 I Pump effeciency
Pump Description:
Pump Efficiency: %
Horsepower Required. #DIVIO! Hp
Thrust Blocking
Thrust Block Area = Thrust I Soil Bearing Strength
Thrust: feet
Soil Bearing Strength: feet
End Cap: #DIVIO! ft2
90 degree elbow: #DIVIO! ft2
Tee: #DIVIO! ft2
45 degree elbow: #DIVIO! ft2
Pie Pressure Rating Check
Pressure Rating of Pipe to be Used: psi
Max. Pressure on system when running: #DIVIO! psi
70% of Pressure Rating: 0 psi
If Max. Pressure on system is less than 70% of Pressure Rating, OK
Net Positive Suction Head Check
Page 2

Sheet7
NPSHA:
NPSHR: *from pump curve
If NPSHA>NPSHR OK
Page 3

Acreage calculations
Pull No. Width Length Start StOp Total Acres
1
262
215
0.7
0.58
2.57
2
240
648
0.68
0.56
4.81
3
262
818
0.35
0.58
5.85
4A
110
181
0.3
0
0.76
4B
252
905
0.68
0
5.92
5A
252
355
0.68
0
2.73
5B
175
1000
0.4
0
4.42
6A
262
899
0.7
0
6.11
6B
262
455
0.7
0
3.44
7A
240
741
0.68
0
4.76
7B
240
408
0.68
0
2.93
8A
240
742
0.68
0
4.77
8B
240
575
0.68
0
3.85
9A
240
750
0.34
0
4.47
9B
240
306
0.68
0
2.37
10A
210
527
0.42
0
2.96
10B
120
222
0.32
0
0.93
11
262
103
0.7
0.58
1.90
12
240
195
0.68
0.56
2.31
13
240
190
0.68
0.56
2.29
14
240
301
0.68
Q.56
2.90
15
240
241
0.68
0.56
2.57
16
240
195
0.68
0.56
2.31
17
240
272
0.68
0.56
2.74
18
240
383
0.68
0.56
3.35
19
262
399
0.68
0.56
3.64
20
284
95
0.7
0.58
1.90
21
120
748
0.36
0.28
2.70
22
220
638
0.62
0.56
4.40
23
220
457
0.62
0.56
3.49
24
180
245
0.34
0.28
1.63
27.06
62.49
12.22

Farm 5572
Scab 1"�;500'�'
— � J
t Total Field = 14.75 Ac.
Cb
�O I
Hog Houses
and
Lagoon
Wells w/100' offsets
>X
1►
Total Field = 33.33 Ac.
Total Field = 70.36 Ac.
�D S
rlr
. / o
q
v�
l

Murphy -Brown, LLC 3/29/2006 2822 Nwy 24 West
P.O. sox 856
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Grower(s):
Farm Name:
Murphy -Brown, LLC
5572
Goun : Robeson
Farm Capacity:
Farrow to Wean
Farrow to Feeder
Farrow to Finish 1200
Wean to Feeder
Feeder to Finish
Storaae Structure: Anaerobic I.
Storage Period:
Application Method:
>180 days
Irrigation
.agoon
nCCEO
APR 0 3 2006
08'R-FA*TryttEREI;i� ACE
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, A tons, etc.):
Ca aci Type Waste Produced per Animal Total
Farrow to Wean
3212 gallyr
gal/yr
Farrow to Feeder
4015 gallyr
gallyr
1200
Farrow to Finish
10585 gallyr
12,702,000 gallyr
Wean to Feeder
223 gallyr
gallyr
Feeder to Finish
986 gallyr
gallyr
Total 12,702,000 gallyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs):
Capacity Type Nitro en Produced per Animal Total
Farrow to Wean
5.4 lbslyr
Ibslyr
Farrow to Feeder
6.5 lbslyr
Ibslyr
1200
Farrow to Finish
26 lbslyr
31,200 Ibslyr
Wean to Feeder
0.48 Ibslyr
Ibslyr
Feeder to Finish
2.3 Ibslyr
Ibslyr
Total 31,200 Ibslyr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 141,56
Total N Required IstYear: 42681.99
Total N Required 2nd Year: 38843.51
Average Annual Nitrogen Requirement of Crops: 40,762.75
Total Nitrogen Produced by Farm: 31,200.00
Nitrogen Balance for Crops: (9,562.75)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2 of 8

Reception Area Specifications
Tract Field irrigated Soil 1st Crop Time to 1st Crop 1st Crop Lbs NIAc Lbs N Total lbs N
Acreage Type Code Apply Yield lbs N)Unit Residual IAc Utilized
2nd Crop Time to 2nd Crop 2nd Crop Lbs NIAc Lbs N Total me N
Code Apply Yield lbs NfUnit Residual /Ac Utilized
Total
Lbs NIAc
Total lbs N
Utilized
34569
1
5.35
Pocalla
C
Mar -Sat
5.0
50
250
1337.5
L
Sept -Apr
1
50
50
267.5
300
1605
2
4.26
Pocalla
C
Mar -Set
5.0
50
250
1065
L i
Sept -Apr
1
50
50
213
300
1278
3
3.4
Pocalla
C
Mar -Set
5.0
50
250
850
L
Sept -Apr
1
50
50
170
300
1020
4A
3.47
Pocalla
C
Mar -Set
5.0
50
250
867.5
L
Sept -Apr
1
50
50
173.5
300
1041
6
48
5.12
Pocalla
C
Mar -Set
5.0
50
250
1280
L
Sept -Apr
1
50
50
256
300
1536
34569
5A
6.38
Pocalla
C
Mar -Sat
5.0
50
250
1595
L
Sept -Apr
1
50
50
319
300
1914
6
5B
6.33
Pocalla
C
Mar -Sept
5.0
50
250
1582.5
L
Sept -Apr
1
50
50
316.5
300
1899
6A
4.82
Pocalla
C
Mar -Sat
5.0
50
250
1205
L
Sept -Apr
1
50
50
241
300
1446
6B
1.87
Pocalla
C
Mar -Set
5.0
5o
250
467.6
L
Se -A r
1
50
50 .
93.5
300
561
7A
3.05
Pocalla
C
Mar -Set
5.0
50
250
762.5
L
Sept -Apr
1
50
SO
152.5
300
915
7B
4.71
Pocalla
C
Mar -Sept
5.0
50
250
1177.5
L
Sept -Apr
1
50
50
235.5
300
1413
8A
4.71
Pocalla
C
Mar -Set
5.0
50
250
1177.5
L
Sept -Apr
1
50
50
235.5
300
1413
8B
2.9
Pocalla
C
Mar -Set
5.0
50
254
725
L
Sept -Apr
1
50
50
145
300
870
9A
4.64
Pocalla
C
Mar -Sept
5,0
50
250
1160
L
Sept -Apr
1
50
50
232
300
1392
99
4.3
Pocalla
C
Mar -Set
5.0
50
250
1075
L
Sept -Apr
1
50
50
215
300
1290
10A
3.48
Pocalla
C
Mar -Set
5.0
50
250
870
L
Se t-A r
1
50
50
174
300
1044
106
2.86
Po(Wia
C I
Mar -Set
5.0 1
54
1
250
715
L
S t-A r
1
50
50
143
300
558
34569
11
2.13
Wa ram
C
Mar -Set
5.5
1 50
1
275
585.75
L
Sept -Apr
1
50
50
106.5
325
692.25
12
2.14
Wa ram
C
Mar -Set
5.5
50
275
588.5
1 L
Sept -Apr
1
50
50
107
325
695.5
13
2.14
Wa ram
C
Mar -Set
5.5
50
275
588.5
1 L
Sept -Apr
1
50
50
107
325
695.5
14
2.81
Wa ram
C
Mar -Set
5.5
50
275
772.75
1 L
Sept -Apr
1
50
50
140.5
325
913.25
15
2.48
Wa ram
C
Mar -Set
5.5
50
275
682
L
Sept -Apr
1
50
50
124
325
806
16
2.14
Wa ram
C
Mar -Set
5.5
50
275
588.5
L
Se t-A r
1
50
50
107
325
695.5
17
2.7
Wa ramI
C
Mar -Set
5.5
50
275
742.5
L
Sept -Apr
1
5o
50
135
325
877.5
18
2.63
Wa ram
C
Mar -Set
5.5
50
275
723.25
L
Sept -Apr
1
50
50
131.5
325
854.75
19
3.73
Wa ram
C
Mar -Set
5.5
50
275
1025,75
L
Se 1-A r
1
50
50
186.5
325
1212.25
20
4.61
W a ram
C
Mar -Sat
5.5
50
275
1267.75
L
Se t-A r
1
50
50
230.5
325
1498.25
21
1.91
Wa ram
C
Mar -Sept
5.5
50
275
525.25
L
Sept -Apr
1
50
5o
95.5
325
620.75
22
4.97
Wa ram
C
Mar -Sept
5.5
50
275
1366.75
L
Sept -Apr
1
50
50
248.5
325
1615,25
23
3.58
Wa rem
C
Mar -Sept
515
50
275
984.5
L
Se t-A r
1
50
50
179
325
1163.5
24
2.92
Wa ram
C
Mar -Set
5.5
50
275
803
L
-Sept-Apr
1
50
50
146
325
949
Sub5-10
1 0.42
Pocalla
C
Mar -Set
5.0
50
250
105
L
Sept -Apr
1
50
50
21
300
126
Subl 1.201
6.27
Wa ram
C
Mar -Sept
5.5
.50
275
1724.25
L
Sa t• r
1
50
50
313.5
325
2037.75
Sub21-241
2.15
Wa ram
C
Mar -Set
5.5
50
275
591.25
L
Se t-A r
1
50
50
107.5
325
698.75
Sub 25
10.87
Wa ram
N
Sept. -April
40.0
2.4
96
1043.52
0
Jun-Septl
25
4
100
1087
196
2130.52
Sub 26
9.31
Goldsboro
N
Sept, -April
60,o
2.4
1"
1340.64
0
Jun -Sept
42
4
168
1664.00
312
2904.72
Totals: 141.56 33961.91 8720.08 42681.99
3(a) of 8

Reception Area Specifications
Tract Field Irrigated Solt 1st Crop Time to 1st Crap ist Crop Lbs NlAc Lbs N Total tbs N
Acrealle Tyea Code Apply Yield Ibs N1Unit Residual tAc Utilized
2nd Crop Time to 2nd Crop 2nd Crop Lbs N1Ac Lbs N Total Ibs N
Code AvDIv Yield ibs NlUnit Residual fAc Utilized
Total
Lbs NlAc
Total tba N
Utilized
34569
1
5,35
Pocalla
C
Mar -Sept
5.0
50
250
1337.5
L
Se t-A r
1
50
50 '
267.5
300
1605
2
4,26
Pocalla
C
Mar -Set
5.0
50
250
1065
L
Se -A r
1
50
50
213
300
1278
3
3.4
Pocalla
C
Mar -Set
5.0
50
250
850
L
Sept -Apr
1
50
50
170
300
1020
4A
3,47
Pocalla
C
Mar -Set
5.0
50
250
867.5
L
Sopt-Apr
1
50
50
173.5
300
1041
6
45
5.12
Pocalla
C
Mar -Sat
5.0
50
250
1280
L
Sept -Apr
1
50
50
256
300
1536
34569
5A
6.38
Pocalla
C
Mar -Sot
5.0
50
250
1595
L
Sept -Apr
1
50
50
1 319
300
1914
6
58
6.33
Pocalla
C
Mar -Set
5.0
50
250
1582.5
1 L
Sept -Apr
1
50
50
316.5
300
1899
6A
4.82
Pocalla
C
Mar -Set
5.0
50
250
1205
L
Se t-A r
1
50
50
241
300
1446
6B
1.87
Pocalla
C
Mar -Sept
5.0
50
250
467.5
L
Sept -Apr
1
50
50
93.5
300
561
7A
3.05
Pocalla
C
-Mar-Sept
5.0
50
250
762.5
L
Sept -Apr
1
50
50
152.5
300
915
7B
4.71
Pocalla
C
Mar -Set
5.0
50
250
1177,5
L
Sept -Apr
1
50
54
235.5
300
1413
8A
4.71
Pocalla
C
Mar -Set
5.0
50
250
1177.5
L
Se t-A r
1
50
50
235.5
300
1413
8B
2.9
Pocalla
C
Mar -Sat
5.6
5o
250
725
L
Sept -Apr
1
1 50
50
145
300
870
9A
4.64
Pocalla
C
Mar -Set
5.0
50
250
1160
L
Sept -Apr
1
50
50
232
300
1392
9B
4.3
Pocalla
C
Mar -Set
5.0 1
50
250
1075
L
Sept -Apr
1
50
50
215
300
1290
t0A
3.48
Pocalla
C
Mar -Sept
5.0
54
1
250
870
L
Sept -Apr
1
50
50
174
300
1044
1013
2,86
Pocalla
C
Mar -Sat
5.0
60
250
715
L
Sept -Apr
1
50
60
143
300
858
34569
11
2.13
Wa ram
C
Mar -Set
5.5
50
275
585.75
L
Sept -Apr
1
50
50
106.5
325
692.25
12
2.14
Wa ram
C
Mar -Sept
5.5
50
275
588.5
L
Se t A r
1
50
50
107
325
695.5
13
1 2.14
We ram
C
Mar -Set
5.5
50
275
588.5
L
Sept -Apr
1
50
50
107
325
695.5
14
2,81
Wa ram
C
Mar -Set
5.5
50
275
772.75
L
Sept -Apr
1
50
5o
140.5
325
913.25
15
2.48
Wa ram
C
Mar -Sept
5.5
1 50
275
682
L
Se t-A r
1
50
1 50
124
325
806
16
2.14
Wa ram
C
Mar -Set
5.5
1 50
1 275
588.5
L
Sept -Apr
1
50
50
107
1 325
695.5
17
2.7
Wa ram
C
Mar -Set
5.5
50
275
742.5
L
Sept -Apr
1
50
50
135
325
877.5
18
2.63
Wa ram
C
Mar -Set
5.5
50
275
723.25
L
Sept -Apr
1
50
50
131.5
325
854.75
19
3.73
Wa ram
C
Mar -Set
5.5
50
275
1025.75
L
Sept -Apr
1
5o
50
186.5
325
1212.25
20
4.61
Wa rem
C
Mar -Set
5.5
50
275
1267.76
L
Sept -Apr
1 1
50
SO
230.5
325
1498.25
21
1.91
Wa ram
C
Mar -Sept
5.5
50
275
525.25
L
Sept -Apr
I 1
5o
50
95.5
325
620.75
22
4.97
Wa ram
C
I Mar -Set
5.5
50
275
1366.75
L
Sept -Apr
1 1
50
50
248.5
325
1615.25
23
3.58
Wa ram
C
Mar -Sept
5.5
50
275
984.5
L
Sept -Apr
I 1
50
1 50
179
325
1163.5
24
2.92
Wa ram
C
Mar -Set
5.5
50
1 275
803
j L
Sept -Apr
f 1
50
50
146
1 325
9"
Sub6-10
0.42
Pocalla
C
Mar -Sept
5.0
50
250
105
L
Sept -Apr
1
50
50
21
300
126
Sub11-20
6.27
Wa ram
C
Mar -Set
5.5
50
275
1724.25
L
Sept -Apr
1
50
50
313.5
325
2037.75
Sub21-24
2.15
Wa ram
C
Mar -Set
5.5
50
275
591.25
L
Sept -Apr
1
50
50
107.5
325
698.75
Sub 25
10.87
wa mm
F
Se t: A ril
550.0
0.12
15
51
554,37
0
0
51
554.37
Sub 26
9.31
Goldsboro
F
Se t: A di
700.0
0.12
15
69
642.39
0
0
69
642.39
Totals., 141.56 32774.51 6069 38843.51
3(b) of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, andlor silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result it small grain gets too high and this Ml definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized 1 unit yield
A
Barley
1.6 lbs N I bushel
B
Hybrid Bermudagrass - Grazed
50 lbs N / ton
C
Hybrid Bermudagrass - Hay
50 lbs N / ton
D
Corn - Grain
125 lbs N / bushel
E
Corn - Silage
12 lbs N / ton
F
Cotton
0.12 lbs N / lbs lint
G
Fescue- Grazed
50 lbs N / ton
H
Fescue - Hay
50 lbs N / ton
I
Oats
1.3 lbs N I bushel
J
Rye
2.4 lbs N / bushel
K
Small Grain - Grazed
50 lbs N 1 acre
L
Small Grain - Hay
50 lbs N / acre
M
Grain Sorghum
2.5 lbs N ! cwt
N
Wheat
2.4 lbs N / bushel
O
Soybean
4.0 lbs N / bushel
P
Pine Trees
40 lbs N 1 acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4 of 8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PANYyrtanimal Farm Tota
Farrow to Wean 0.84
Farrow to Feeder 1
1200 Farrow to Finish 4.1 4920
Wean to Feeder 0.072
Feeder to Finish 0.36
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 4920 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 24600 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 82 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 196.8 acres of land. Please note that these'
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
"This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract
Hydrant
Type
Crop
inlhr
* inches
34569
1
Pocalla
C
0.45
1
2
Pocalla
C
0.45
1
3
Pocalla
C
.0.45
1
4A
Pocalla
C
0.45
1
6
4B
Pocalla
C
0.45
1
34569
5A
Pocalla
C
0.45
1
6
5B
Pocalla
C
0.45
1
6A
Pocalla
C
0.45
1
6B
Pocalla
C
0.45
1
7A
Pocalla
C
0.45
1
7B
Pocalla
C
0.45
1
8A
Pocalla
C
0.45
1
8B
Pocalla
C
0.45
1
9A
Pocalla
C
0.45
1
9B
Pocalla
C
0.45
1
10A
Pocalla
C
'0.45
1
1013
Pocalla
C
0.45
1
34569
11
Wagram
C
0.6
1
12
Wagram
C
0.6
1
13
Wagram
C
0.6
1
14
Wagram
C
0.6
1
15
Wagram
C
0.6
1
16
Wagram
C
0.6
1
17
Wagram
C
0.6
1
18
Wagram
C
0.6
1
19
Wagram
C
0.6
1
20
Wagram
C
0.6
1
21
Wagram
C
0.6
1
22
Wagram
C
0.6
1
23
Wagram
C
0.6
1
24
Wagram
C
0.6
1
Sub6-10
Pocalla
C
0.45
1
Sub11-20
Wagram
C
0.6
1
Sub21-24
Wagram
C
0.6
1
Sub 25
Wagram
N
0.6
1
Sub 26
Goldsboro
N
0.4
1
6 of 8

Additional Comments:
Subfield acreage listed on this plan is the balance of total field acres minus
wet acres for this site. This acreage will be claimed when making application
with an aerway machine.
Only change for this plan is subfields 25 and 26. It was taken out of Bermuda and
7of8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: 5572
Owner: Murphy -Brown, LLC
Manager:
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. Itwe know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Mur h -Brown, LLC
i
Signature: � N )kcal
Name of Manager (if different from own4)
.V + ���� • n
Signature:
Date
Name of Technical Specialist:
Amy E. Roberson
Affiliation:
Murphy -Brown, LLC.
Address:
2822 Hwy 24 West, PO Drawer 856
Warsaw, NC 28398
Telephone:
[phone]
Signature:
a
0
8 of 8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recieving crop type, or available land_
Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies,
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Wastelnutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with .the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2of3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which. will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels_ pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3of3

Facility
Waste Management Plan Changes
-��-[Z./
Farm 7
RECEIVED
JUN 16 2005
DENR - FAYEi'FEUILLE REGIONAL OFFICE
This farms Waste Management Plan has made the following changes:
❑ Crop changes
❑ Wetted Acres
❑ Increased Acreage
❑ Decreased Acreage
❑ Changed Irrigation Design
❑ Change in Farm type
❑ Plan based on 3 Years On Farm Records
other
Continents:
Date

Murphy -Brown, LLC
Grower(s):
Farm Name:
6/14/2005 2822 Hwy 24 West
P.O. Box 856
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Murphy -Brown, LLC
7572
County: Robeson
Farm Capacity:
Farrow to Wean
Farrow to Feeder
Farrow to Finish 1200
Wean to Feeder
Feeder to Finish
Storage Structure: Anaerobic
Storage Period:
Application Method:
>180 days
Irrigation
Lagoon
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown_
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations_
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied_ Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2F1 .0217 adopted by the Environmental Management Commission,
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, It tons, etc.):
Capacity Type Waste Produced per Animal Total
Farrow to Wean
3212 gallyr
gal/yr
Farrow to Feeder
4015 gal/yr
galtyr
1200
Farrow to Finish
10585 galtyr
12,702,000 gallyr
Wean to Feeder
223 galtyr
gal/yr
Feeder to Finish
986 gallyr
Qallyr
Total 12,702,000 gallyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (Ibs):
Ca aci !Yee Nitrogen Produced per Animal Total
Farrow to Wean
5.4 lbs/yr
lbs/yr
Farrow to Feeder
6.5 lbs/yr
lbs/yr
1200
Farrow to Finish
26 lbs/yr
31,200 lbs/yr
Wean to Feeder
0.48 lbs/yr
lbs/yr
Feeder to Finish
2.3 lbs!
lbs/yr
Total 31,20D lbs/yr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 121.38
Total N Required 1st Year: 37646.75
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops: 37,646.75
Total Nitrogen Produced by Farm: 31,200.00
Nitrogen Balance for Crops: (6,446.75)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2of8

Reception Area Specifications
Tract Field Irrigated Soil 1st Crop Time to 1st Crop 1st Crop Lbs MAc Lbs N Total Ibs N
Acreage Type Code Apply Yield Ibs MUnit Residual /Ac Utilized
2nd Crop Time to 2nd Crop 2nd Crop Lbs MAC Lb$ N Total ms N
Code Apply Yield lips MUnit Residua! JAc Utilized
Total
Lbs MAc
Total The N
Utilized
34569
1
5.35
Pocail8
C
Mar -Set
5.0
50
250
1337.5
L
Sept -Apr
1
50
50
267.5
300
1605
2
4.26
Pocalla
C
Mar -Set
5.0
5o
250
1065
L
Se t-A r
1
50
5o
213
300
1278
3
3.4
Pocalla
C
Mar -Set
5.0
50
250
850
L
Sept -Apr
1
50
50
170
300
1020
4A
3.47
Pocalla
C
Mar -Set
5.0
50
250
867.5
L
5e t-A r
1
50
5o
173.5
300
1041
6
46
5.12
Pocalla
C
Mar -Set
5.0
50
250
1280
L
Sept -Apr
1
50
50
256
300
1536
34569
5A
6,38
Pocalla
C
Mar -Set
5.0
50
250
1595
L
Sept -Apr 1
1
50
50
319 1
300
1914
6 1
58 1
6.33
Pocalla
C
Mar -Set
5.0 1
50
250
1582.5
L
Sept -Apr
1
50
50
316.5 1
300
1899
6A
4.82
Pocalla
C
Mar -Set
5.0
50
250
1205
L
Sapt-,Apr
1
50
5o
241
300
1446
6B
1.87
Pocalla
C
Mar -Set
5.0
50
250
467.5
L
Sept-Aw
1
50
50
93.5
300
561
7A
3.05
Pocala
C
Mar -Set
5.0
50
250
762.5
L
Sept-AprSept-Apr
1
50
50
152.5
300
915
7B
4.71
Pocalla
C
Mar -Set
5.0
50
250
1177.5
L
Sept -Apr
1
50
50
235.5
300
1413
SA
4.71
Pocalla
C
MarSe i
5.0
50
250
1177.5
L
Se -A r
1
50
50
235.5
300
1413
8B
2.9
Pocalla
C
Mar -Set
5.0
50 1
250 1
725
L
Sept -Apr
1
50
50
145
300
870
9A
4.64
Pocalla
C I
MarSe t
5.0
50
250
1160
L
Sept -Apr 1
1
50
50
232
300
1392
9B
4.3
Pocalla
C
Mar -Sept
5.0
50
250
1075
L
Se t-A r
1
50
50
215
300
1290
10A
3.48
Pocalla
C
Mar -Set
5.0
50
250
570
L
Sept -Apr
1
50
50
174
300
1044
10B
2.86
Pocalla
C
Mar -Sept
5.0
50
250
715
L
Sept -Apr
1
50
50
143
300
858
34%9
11
2.13
Wa ram
C
Mar -Sept
5.5
50
275
585.75
L
Sept -Apr
1
50
50
105.5
1 325
692.25
12
2.14
wa ram
C
Mar -Set
5.5
50
275
588.5
L
Sept -Apr
1
50
50
107
1 325
695.5
13
2.14
Wa €am
C
Mar -Set
5.5 t
50
275
588.5
L
Sept-AprSept-Apr
1
50
50
107
t 325
695.5
14
2,81
VYa ram
C
Mar -Set
5.5
50
275
772.75
L
Sept -Apr.
1
50
50
140.5
325
913.25
15
2.48
Wa ram
C
Mar -Set
5.5
50
275
682
L
Sept -Apr
1
50
50
124
325
806
16
2,14
Wa ram
C
Mar -Set
5.5
50
275
588.5
L
Sept -Apr
1
50
50
107
325
695.5
17
2.7
Wa ram
C
Mar -Set
5.5
50
275
742.5
L
Sept -Apr
1
50
50
135
325
877.5
18
2.63
W a ram
C
MarSe t
5.5
50
275
723.25
L
Se t-A r
1
50
5o
131.5
325
854.75
19
3.73
Wa ram
C
Mar -Set
5.5
50
275
1025.75
L
Sept -Apr
1
50
50
186.5
325
1 1212.25
20
4.61
wa ram
C
Mar -Set
5.5
50
275
1267.75
L
Sept -Apr
1 1
50
1
50
230.5
325
1498.25
21
1.91
Wa ram
C
Mar -set
5.5
50
275
525.25
L
Sept -Apr
1 1
50
1
50
95.5
325
620.75
22
4.97
Wa ram
C
I Mar -Set
5.5
50
275
1366.75
L
Sept -Apr
1
50
50
248.5
325
1615.25
23
3.58
wa ram
C
Mar -Sept
5.5
50
275
984.5
L
Septr
1
50
50
179
325
1163.5
24
2.92
Wa ram
C
Mar -Set
5.5
50
275
803
L
Sa t-A r
1
50
50
146
325
949
Sub6-10
0.42
Pocalla
C
Mar -Set
5.0
50
250
105
L
Sept -Apr
1
50
50
21
300
126
Subl1-20
6.27
wa ram
C
Mar -Sept
5.5
50
275
1724.25
L
So t-A r
1
50
50
313.5
325
2037,75
Sub21-24
2.15
Wa ram
C
Mar -Set
5.5
50
275
591.25
L
Sept -Apr
1
50
50
107.5
325
698.75
Totals: 121.38 31577.76 6069 376r8.75
3(a) of 8

Reception Area Specifications
3(h) of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized / unit yield
A
Barley
1.6 lbs N / bushel
B
Hybrid Bermudagrass - Grazed
50 lbs N / ton
C
Hybrid Bermudagrass - Hay
50 lbs N 1 ton
D
Corn - Grain
1.25 lbs N / bushel
E
Com - Silage
12 lbs N / ton
F
Cotton
0.12 lbs N / lbs lint
G
Fescue- Grazed
50 lbs N 1 ton
H
Fescue - Hay
50 lbs N / ton
I
Oats
1.3 lbs N / bushel
J
Rye
2.4 lbs N / bushel
K
Small Grain - Grazed
50 lbs N 1 acre
L
Small Grain - Hay
50 lbs N / acre
M
Grain Sorghum
2.5 lbs N / cwt
N
Wheat
2.4 1bs N / bushel
0
Soybean
4.0 lbs N / bushel
P
Pine Trees
40 lbs N / acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4 of 8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PAN
/animal Farm TotaVyr
Farrow to Wean
0.84
Farrow to Feeder
1
1200 Farrow to Finish
4.1 4920
Wean to Feeder
0.072
Feeder to Finish
0.36
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 4920 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 24600 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 82 acreas of land. If you apply the sludge
to cam at a rate of 125 pounds per acre, you will need 196.8 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
'This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions_
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract
Hydrant
Type
Crop
inlhr
* inches
34569
1
Pocalla
C
0.45
1
2
Pocalla
C
0.45
1
3
Pocalla
C
0.45
1
4A
Pocalla
C
0.45
1
6
4B
Pocalla
C
0.45
1
34569
5A
Pocalla
C
0.45
1
6
5B
Pocalla
C
0.45
1
6A
Pocalla
C
0.45
1
6B
Pocalla
C
0.45
1
7A
Pocalla
C
0.45
1
7B
Pocalla
C
0.45
1
8A
Pocalla
C
0.45
1
8B
Pocalla
C
0.45
1
9A
Pocalla
C
0.45
1
9B
Pocalla
C
0.45
1
10A
Pocalla
C
0.45
1
10B
Pocalla
C
0.45
1
34569
11
Wagram
C
0.6
1
12
Wagram
C
0.6
1
13
Wagram
C
0.6
1
14
Wagram
C
0.6
1
15
Wagram
C
0.6
1
16
Wagram
C
0.6
1
17
Wagram
C
0.6
1
18
Wagram
C
0.6
1
19
Wagram
C
0.6
1
20
Wagram
C
0.6
1
21
Wagram
C
0.6
1
22
Wagram
C
0.6
1
23
Wagram
C
0.6
1
24
Wagram
C
0.6
1
Sub6-10
Pocalla
C
0.45
1
Sub11-20
Wagram
C
0.6
1
Sub21-24
Wagram
C
0.6
1
6of8

Additional Comments:
Subfield acreage listed on this plan is the balance of total field acres minus
wet acres for this site. This acreage will be claimed when making application
with an aerway machine.
7 of 8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: 7572
Owner: Murphy -Brown, LLC
Manager:
Owner/Manager Agreement:
I/we understand and wilt follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Murphy -Brown, LLC
Signature:
Date
Name of Manager (if different frorp owner):
Signature:
17 Date
Name of Technical Specialist: Dawn Williamson
Affiliation: Murphy -Brown, LLC.
Signature:
Address: 2822 Hwy 24 West, PO Drawer 856
Warsaw, NC 28398
Telephone: [phone]
Date
8of8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to property dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recieving crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Wasteinutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2of3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc_,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3of3

0� W A r� Michael F. Easley, Governor
Q William G. Ross Jr., Secretary
7 North Carolina Department of Environtncnt and Natural Resources
=� Alan W. Klimek, P.E. Director
p Division of Water Quality
October 15, 2004
Carroll's Foods Inc
Farm 7572
PO Box 759
Rose Hill NC 28458
RECEIVED
OCT Z 9 ZOO
OEM-FAYETIE1 UfRMOMLOMCE
Subject: Certificate of Coverage No. NCA278012
Farm 7572
Swine Waste Collection, Treatment,
Storage and Application System
Robeson County
Dear Carroll's Foods Inc:
In accordance with your application received on August 24, 2004, we are hereby forwarding to you this
Certificate of Coverage (COC) issued to Carroll's Foods Inc, authorizing the operation of the subject
animal waste collection, treatment, storage and land application system in accordance with NPDES
General Permit NCA200000.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Farm 7572, located in Robeson County, with an animal capacity of no greater
than an annual average of 1200 Farrow to Finish swine and the application to land as specified in the
facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or Farrow to
Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary, they may
be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a rate of 4
gilts for every 3 sows
The COC shall be effective from the date of issuance until July 1, 2007, and shall hereby void Certificate
of Coverage Number AWS780012 dated May 1, 2003, and shall be subject to the conditions and
limitations as specified therein. Pursuant to this COC, you are authorized and required to operate the
system in conformity with the conditions and limitations as specified in the General Permit, the facility's
CAWMP, and this COC. An adequate system for collecting and maintaining the required monitoring data
and operational information must be established for this facility. Any increase in waste production
greater than the certified design capacity or increase in number of animals authorized by this COC (as
provided above) will require a modification to the CAWMP and this COC and must be completed prior to
actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed General Permit. Since this is a new joint State and
Federal general permit it contains many new requirements in addition to most of the conditions contained
in the current State general permit. Enclosed for your convenience is a package containing the new and
revised forms used for record keeping and reporting. Please pay careful attention to the record keeping
and monitoring conditions in this uermit. The Devices to Automaticallv Stop Irrigation Events Form
must be returned to the Division of Water Quality no later than 120 days following, receipt of the
Certificate of Coverage. The Animal Facility Annual Certification Form must be completed and returned
to the Division of Water Quality by no later than March 1 st of each year.
N- CaroIii.
Aquifer Protection Section 1636 Mail Service Center Raleigh NC 27699-1636 Phone [phone] Customer Service V "'tA(rQ11P
Internet: httpJlh2o.enr.state.nc.us 2728 Capital Boulevard Raleigh, NC 27604 Fax [phone]
Fax [phone]
An Equal Opportunity/Af6rrnabve Action Employer— 50% Recycled110% Post Consumer Paper

If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 2H .0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100 foot separation
shall be maintained between water supply wells and any lagoon or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C, the Clean Water Act and 40 CFR 122.41 including civil penalties, criminal
penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual NPDES Permit by contacting the staff member listed below for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Aquifer Protection Staff may be reached at [phone]. If you need additional information
concerning this COC or the General Permit, please contact J. R. Joshi at [phone].
Sincerely,
v
for Alan W. Klimek, P.E.
Enclosures (General Permit NCA200000, Record Keeping and Reporting Package)
cc: (Certificate of Coverage only for all cc's)
Robeson County Health Department
Fayetteville Regional Office, Aquifer Protection Section
Robeson County Soil and Water Conservation District
Permit File NCA278012
APS Files

Michael F. Easley
Governor
William G. Ross Jr., Secretary
Department of Environment and Natural Resources
p Alan W. Klimek, P.E. Director
Division of Water Quality
April 16, 2003
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Carroll's Foods Inc
PO Box 759
Rose Hill NC 28458
SUB.iECT: Notice of Violation
Request for Information
Inadequate Freeboard
7572
#78-12
Robeson County
Dear Sir or Madam:
3 2003
I k--
On March 7, 2003, a representative of your animal operation informed the Division of
Water Quality (DWQ) that there was inadequate freeboard in the lagoon(s) serving this facility.
This lack of adequate freeboard is in non-compliance with the Certificate of Coverage
issued to this facility on May 29, 1997. In addition to this Notice of Violation (NOV), this non-
compliance is subject to an appropriate enforcement action by DWQ. This action can consist of
one or more of the following: a civil or criminal enforcement action; an injunction; and/or a
requirement to apply for coverage under an individual permit.. The action chosen will be based
on complete evaluation of all factors that resulted in the inadequate freeboard; the actions taken
to restore the needed freeboard; and the actions being proposed to prevent the problem from
reoccurring.
To assist us in our review, please provide the Fayetteville Regional Office with an
evaluation of the reasons for the freeboard violation(s) and a strategy to prevent future freeboard
violation(s). This evaluation and strategy must include but is not limited to the following:
Current Freeboard level(s)
Freeboard level records in the lagoon(s) for the past 12 months up to the date of submittal
Spraying records for the past 12 months up to the date of submittal
AMA
N NR
Customer Service: Mailing Address: Telephone [phone] Location:
1-877-623-6748 1617 Mail Service Center Fax [phone] N. Salisbury St.
Raleigh, North Carolina 27699-1617 State Courier #52-01-01 Raleigh, NC 27699-1617
An Equal Opportunity / Rffimrative ,fiction Employer
50% recyded / 10% past -consumer paper
httpJ/h2o.enr state.nc. us

Inadequate Freeboard
Page 2
Rainfall records for the past 12 months for this site up to the date of submittal (if
available)
Cropping system and PAN specified in the CAWMP. If the cropping system was not in
compliance with the facility's CAWMP, provide details of the cropping system in place
for the past 12 months.
A summary of actions taken to restore the needed freeboard in the lagoon(s) including but
not limited to removal of animals from the site, delay of restocking of animals, pumping
and hauling waste to another site (specify site), securing additional irrigation equipment,
and securing additional spray sites.
A description of water conservation measures in use at the facility and the date(s)
installed.
If the lagoon level(s) are still in violation of the facility's CAWMP and Permit, provide
an updated Plan of Action as to how the facility will return to compliance.
Provide a detailed description of the actions taken or proposed to be taken to insure that
there are no further freeboard violations at this facility.
This information must be received by the Fayetteville Regional Office at the following
address no later than 10 days following receipt of this letter.
Division of Water Quality
225 Green Street, Suite 714
Fayetteville, NC 28301-5043
Once this information is received and evaluated by the DWQ staff, a determination will
be made as to the appropriate compliance/enforcement actions to be taken. Each case will be
evaluated on its own merit. The efforts by the owner/producer to notify DWQ of the problem,
efforts made to resolve the problem once identified, and efforts proposed to prevent future
problems will be positive factors in this determination.
Nothing in this letter should be taken as removing from you either the responsibility or
liability for this non-compliance or future cases of non-compliance. If you have any questions
regarding this letter, please do not hesitate to contact our Fayetteville Regional Office Staff at
[phone].
Sincerely,
le Alan W. Klimek, P.E.
Director
cc: Fayetteville Regional Office
Non -Discharge Compliance/Enforcement Unit
Central Files

Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per NRCS standards a 100 foot separation shall be maintained between water supply wells and any
lagoon or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such.a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact J R Joshi at [phone] ext. 363.
Sincerely,
v
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG 100000)
cc: (Certificate of Coverage only for all cc's)
Fayetteville Regional Office, Water Quality Section
Robeson County Health Department
Robeson County Soil and Water Conservation District
Permit File AWS780012
NDPU Files

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P. E_, Director
Division of Water Quality
May 1, 2003
Carroll's Foods Inc
7572
PO Box 759
Rose Hill NC 28458
Subject: Certificate of Coverage No. AWS780012
7572
Swine Waste Collection, Treatment,
Storage and Application System
Robeson -County
Dear Carroll's Foods Inc:
On April 28, 2003, the North Carolina General Assembly ratified Senate Bill 733 which directs the
Division of Water Quality (Division) to extend the expiration date of the Swine.Waste Operation -General
Permit AWG100000. Therefore, the General Permit has been re -issued by the Division to extend the
expiration date to October 1, 2004. During the period of this extension the Division will be working with
all interested parties on the development of a new version of the Non -Discharge General Permit.
In accordance with your application received on February 13, 2003 and in accordance with the directive
of Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to
Carroll's Foods Inc, authorizing the operation of the subject animal waste collection, treatment, storage
and land application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AWS780012 which expired on April 30, 2003.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the 7572, located in Robeson County, with an animal capacity of no greater than an
annual average of 1200 Farrow to Finish swine and the application to land as specified in the facility's
Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or Farrow to Feeder
operation, there may also be one boar for each 15 sows. Where boars are unneccessary, they may be
replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a rate of 4 gilts
for every 3 sows
The COC shall be effective from the date of issuance until October 1, 2004. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property. MAW
1�11 flit
Non -Discharge t ermitting Unit Internet http:Yh2o.enr.state.nc.us/ndpu
1617 Mail Service Center, Raleigh, NC 27699-1617 Telephone [phone] Fax [phone]
Customer Service Center Telephone [phone]
An Equal opportunity Action Employer 50% recycled/10% post -consumer paper

Nutrient Management Plan For Animal Waste Utilization
05-09-2001
This plan has been prepared for:
Farm 7572
Carrolls Laurinburg
P.O. Box 1767
Laurinburg, NC 28353
910-276-0648
This plan has been developed by:
DA WN WILLIAMSON
PRIVA TE
P.O. BOX 856
WAR SA W, NC 28398
9�10-59�2(-0141 246
Developer Signature
Type of Plan: Nitrogen Only with Manure Only
Owner/Manager/Producer Agreement
I (we) understand and agree to the specifications and the operation and maintenance
procedures established in this nutrient management plan which includes an animal waste
utilization plan for the farm named above. t have read and understand the Required
Specifications concerning animal waste management that are included with this plan.
Signature (owner)
Signature (manager or producer)
Date
5-1-2
Date
This plan meets the minimum standards and specifications of the U.S. Department of
Agriculture - Natural Resources Conservation Service or the standard of practices adopted
by the Soil and Water Conservation Commission.
Plan Approved By:
Technical Specialist Signature Date
Preview Database Version 1.05- Date Printed: 0-09-2001 Cox•cr Page 1

Nutrients applied in accordance with this plan will be supplied from the
following source(s);
Commercial Fertilizer is not included in this plan.
S13
Swine Farrow -Finish Lagoon Liquid waste generated 12,573,600 gals/year
by a 1,200 animal Swine Farrow -Finish Lagoon Liquid operation. This
production facility has waste storage capacities of Mproximately 180 days.
Estimated Pounds of Plant Available Nitrogen Generated per Year
Broadcast
28977
Incorporated
49765
Injected
54805
Irrigated
31497
Actual PAN Applied
Year 1
37148
Notes:
In source ID, S means standard source, U means user defined source
.................................................................................. ......................
805126 Database Version 1 05 Date Printed: 05-09-2001 Source Page I

The Waste Utilization table shown below summarizes the waste utilization plan for this operation. This plan provides an estimate of the number of acres of cropland
needed to use the nutrients being produced. The plan requires consideration of the realistic yields of the crops to be grown, their nutrient requirements, and proper
timing of applications to maximize nutrient uptake.
This table provides an estimate of the amount of nitrogen required by the crop being grown and an estimate of the nitrogen amount being supplied by manure or other
by-products, commercial fertilizer and residual from previous crops. An estimate of the quantity of solid and liquid waste that will be applied on each field in order to
supply the indicated quantity of nitrogen from each source is also included.
A balance of the total manure produced and the total manure applied is included in the table to ensure that the plan adequately provides for the utilization of the
manure generated by the operation, Animal operations that generate liquid waste and utilize waste storage facilities (lagoons or holding ponds) may apply more or
less waste in any given year than is annually generated by the facility. in order to determine whether the plan adequately utilizes the waste produced by the facility,
the storage capacity table included in this plan should be reviewed to ensure that the design capacity of the storage facility is not exceeded during the planning period.
Depending on the requirements of the crop and the nutrient content of the waste, some nutrients will likely be over or under applied if animal waste is being utilized.
Waste should be analyzed before each application cycle and annual soil tests are required if animal waste is being applied. Soil tests should be used to balance the
nutrient application amounts with the realistic yields of the crop to be grown. Nutrient management plans may require that the application of animal waste be limited
so as to prevent over application of phosphorous when excessive levels of this nutrient are detected in a field.
Waste Utilization Table Year l
"tract
I Field
Source
LI).
I Soil Series
Total
Acre
Use.
Acres
I Crop
RYE
RYE
1 Unit
Applic.
Period
Nitrogen
PA
Nutrient
Req'd
1b%IA
Conan.
Fert.
Nutrient
Applied
1bs1A
Res.
(lbs/A)
Applic.
Method
Manure
PA
Nutrient
Applied
Liquid
Manure
Applied
(acre)
Solid
Manure
Applied
(acre)
Liquid
Manure
Applied
(Field)
Solid
Manure
Applied
(Field)
N
N
N
I Ibs/A
1000
al/A
tons
I 1000 als
toes
34569
1
S13
Pocalla
5.3
53
Bermuda ass Hay
*5.6
Tons
311-9130
* 275
0
0
Irri .
275
109.8
0.0
5873
0.0
34569
1
S13
Puealla
5.3
5.3
SnlallGralnOverseed
1.0
Tons
1011-3/31
50
0
0
ltri .
50
20,0
0.0
106.8
0.0
34569
10A
S13
Pocalla
3.5
3.5
Bermuda ass Hay
*5.6
Tons
3/1-9130
' 275
0
0
Irri .
275
109.8
0.0
382.0
0.0
34569
10A
S13
PoeaIla
3.5
3.5
Small Grain Overseed
1,0
Tons
1011-3/31
50
0
0
Irri .
50
20.0
0.0
69.5
0.0
34569
IOB
S13
Pocalla
2.9
2.9
Bernmda ass Hay
*5.6
Tons
3/1-9/30
' 2751
0
0
Irri .
275
109.8
0.0
314.0
0.0
34569
10B
S13
Pocalla
2.9
2.9
Small Grain Overseed
1.0
Tons
1011-3131
50
0
0
Irri .
50
20,0
0.0
57.1
0.0
34569
II
S13
Wagrarn
2.1
2.1
BerntUdagrass Hay
*5.6
Tans
3/1-9/30
• 275
0
0
Irri ,
275
109.8
0.0
233.8
0.0
34569
11
S l3
Wignarn
2.1
2.1
Cereal/Annual Rve O/S,
2.0
Tons
*9/15-3/31
100
0
0
Inri ,
75
29.9
0.0
63.8
0.0
34569
12
S13
Wagrarn
2.1
2.1
Bermuda ass Hap
*5,6
Tons
3/1-9/30
* 275
0
0
Irri .
275
109.8
0.0
234.9
0.0
34569
12
S 13
Wagrnrn
2. I
2.l
Cereal/Mutual Rye O/S,
2.0
Tons
1 *9/15-3/31
100
Ol
0 1
Inig.
1 751
29.9
0.01
64.1
0.0
............................................................................................................................................................................................................................................................................ -.................................................. .. .-...............
805126 Database Version 1.05 Date Printed: 05-09-2001 VPJT Page I

Waste Utilization Table Year 1
Tract
Field
Source
I.D.
Soil series
Total
Acre
Use.
Acres
Crop
RYE I
RYE
Unit
Applic,
Period
Nitrogen
PA
Nutrient
Req'd
(lbs1A)
Comm.
Fen.
Nutrient
Applied
(1bs/A
Res. 11
(lbs1A)
Applic,
Method
Manure
PA
Nutrient
Applied
Liquid
Manure
Applied
(acre)
Solid
Manure
Applied
(acre)
Liquid
Manure
Applied
(Field)
Solid
Manure
Applied
(Field)
N
N
N
lbs/A
1000
valtA
tons
1000 eals
tons
34569
13
S13
Wagram
2.1
2.1
Bermuda Hay
*5.6
Tons
3/1.9/30
` 275
0
0
Iri .
275
109.8
0.0
2343
0.0
34569
13
S13
Wa am
2.1
2.1
Cereal/Annual Rye 015,
2.0
Tons
*9115-3/31
l00
0
0
Irri .
75
29.9
0.0
64.1
0.0
34569
14
S13
Wagram
2.8
2.8
Bermuda ssHay
*5,6
Tons
3/I-9130
* 275
0
0
Iri ,
275
109.8
0.0
308.5
0.0
34569
14
S13
Wagram
2.8
2.8
Cereal/Annual RveO/S,
2.0
Tons
'9/15.3/31
100
0
0
]rig.
75
29.9
0.0
84.1
0.0
34569
IS
S13
Wa am
2.5
2.5
Bermuda ass Hay
'5.6
Tons
311-9/30
* 275
0
0
Irri .
275
109.8
0.0
272.3
0.0
34569
151
S13
Wa am
2.5
2.5
Cereal/Annual Rye O/S,
2.0
Tons
*9/15-3/3 l
100
0
0
Irti
75
29.9
0.0
74.3
0.0
34569
16
S13
Wa am
2.1
2.1
Bermuda ass Ha
*5,6
Tons
311-9/30
• 275
0
0
Irti .
275
109.8
0.0
234.9
0.0
34569
16
S13
Wa am
2.1
2.1
Cereal/Annual Rve O/S,
2.0
Tons
*9/15.3131
100
0
0
Iri
75
29.9
0.0
64.1
0.0
34569
17
S13
Wa am
2.7
2.7
Bermuda ass Hay
*5.6
Tons
3/1-9/30
* 275
0
0
Iri
275
109.9
0.0
296.4
0.0
34569
17
S13
Wa am
2.7
2.7
CereallArmual Rve OIS,
2.0
Tons
49/15.3131
100
0
0
Iri
75
29.9
0.0
90.8
0.0
34569
18
S13
Wagram
2.6
2.6
Bermuda ass Hay
*5.6
Tons
3/1.9/30
275
0
0
Iri .
275
109.8
0.0
288.7
0.0
14%9
IS
S13
Wagram
2.6
2.6
Cereal/Annual Rye O1S,
2.0
Tons
*9/15-3/31
100
0
0
Iri .
75
29.9
0.0
78.7
0.0
34569
19
S13
Wagrain
3.7
3.7
B=Wdagrass Hay
*5.6
Tons
311-9/30
' 275
0
0
Iri .
275
109.8
0.0
409.5
0.0
34569
19
S13
Wagram
3.7
3.7
Cereal/Annual RveO/S,
2.0
Tons
*9/I5-3/31
100
0
0
Iri .
75
29.9
0.0
111.7
0.0
34569
2
S13
Pocalla
4.3
4.3
13ernurda rass Ilav
`5.6
T•ons
311-9130
' 275
0
0
Iri .
275
109.8
0.0
467.7
0.0
34569
2
S13
Pocalla
4.3
4.3
Small Grain Overseed
1.0
Tons
1011.3131
50
0
0
Irri .
50
20.0
0.0
85.0
0,0
34569
20
S13
Wa am
4.61
4.6
BermudagrassHav
•5.6
Tons
3/1-9/30
* 275
0
0
Irig.
275
109.8
0.0
506.1
0.0
34569
20
SO
Wasiam
4.6
4,6
Small GrainOverseed
1.0
Tons
1011-3/31
50
0
0
Iri .
50
20M
0.0
92.0
0.0
34569
21
S13
lVagram
1.9
1.9
Bennuda assHav
*5.6
Tons
311-9130
• 275
0
0
Irrig,
275
109.8
0.0
209.7
0.0
34569
21
S13
Wazrani
19
1.9
Small GrainOverseed
1.0
Tons
10/1.3/31
50
0
0
Irrig.
50
20.0
0.0
38.1
0.0
34569
22
S13
Wagram
5.0
5.0
Bermuda ass Ha
*5.6
Tons
3/1-9/30
* 275
0
0
Irri&
275
109.8
0.01
545.6
0.0
34569
22
S13
Wagram
5.0
5.0
Small Grain Overseed
1.0
Tons
1 1011-3131
501
0
01
Irrip,
50
20.0
0.0
99.2
0.0
34569
23
S13
Wagram
3.6
3.6
Bermuda ass Hay
*5.6
Tons
311-9/30
' 275
0
0
Iri .
275
109.8
0.0
393.0
0.0
34569
23
S13
Wagram
3.6
3.6
Small Grain Overseed
1.0
Tons
1011-3/31
50
0
0
Iri .
50
20.0
0.0
71.5
0.0
34569
24
813
Wagram
2.9
2.9
Bennuda ass Hay
*5.6
Tons
3/1-9/30
* 275
0
0
It -rig,
275
109.8
0.0
320.6
0.0
34569
24
S 13
1 Wagram
2.9
2.9
1 Small Grain Overseed
1.0
Tons
1011-3/31
50
0
0
Iris.
50
20.0
0.0
58.3
0.0
34569
3
S13
Pocalla
3.4
3.4
Bennuda ss Hav
'5.6
Tons
3/1-9/30
• 275
0
0
Irri .
275
109.8
0.01
373.3
0.0
34569
3
S 13
Pocalla
3.4
3.4
Small Grain Overseed
1.0
Tons
1011-3/31
30
0
0
50
20.0
0.0
67.9
0.0
34569
4A
S13
Pocalla
3.5
3.5
Bermuda ss Hay
'5.6
Tons
3/1.9130
' 275
0
0
275
109.8
0.0
380.9
0.0
34569
4A
S13
Pocalla
3.5
3.5
Small Grain Overseed
1.0
Tons
1011-3/31
50
0
0
$Irtig,
50
20.0
0.0
69.3
0.0
34569
413
S13
Pocalla
3.1
5A
Bennuda ss Hav
*5.6
Tons
3/1-9130
• 275
0
0
275
109.8
0.0
562.1
0.0
34569
43
S13
Pocalla
5.1
5.1
Small Grain Overseed
1.0
Tons
1011.3/31
50
0
0
50
20.0
0.0
102.2
0.0
34569
5A
S13
Pocalla
6.4
6.4
Bermuda ssHav
05.6
Tons
3/1.9130
* 275
0
0
275
109.8
0.01
700.4
0.0
............... ..................... ---- .......................... ........................ .......-.................... ............................................. ....... ........... ................................. .......... ......................... ................................................................................
-
805126 Database Version 1,05 Date Printed: OM9-2001 WUT Page 2

Waste Utilization Table Year 1
Tract
Field
Source
1.D.
Soil Series
Total
Acre
Use,
Acres
Crop
RYE
RYE
Unit
Applic.
Period
Nitrogen
PA
Nutrient
Req'd
(Ibs1A)
Comm.
Fert.
Nutrient
Applied
(lbs/A)
Res.
(lbs/A)
Applic,
Method
Manure
PA
Nutrient
Applied
Liquid
Manure
Applied
(acre)
Solid
Manure
Applied
(acre)
Liquid
Manure
Applied
(Field)
Solid
Manure
Applied
(Field)
N
N
N
Ibs/A
1000
al/A
tons
I 1000 pals
tons
34569
5A
S13
Pocalla
6.4
6.4
Small Grain Overseed
1.0
Tons
10/1-3131
50
0
0
Irri .
50
20.0
0.0
127.3
0.0
34569
513
S13
Pocalla
6.3
6.3
Bermuda ass Hay
'5.6
Tons
3/1.9/30
• 275
0
0
Iri .
275
109.8
0.01
694.9
0.0
34569
513
S13
Pocalla
6.3
6.3
Small Grain Overseed
1,0
Tons
10/1-3131
50
0
0
Irri .
50
20.0
o.01
126.3
0.0
34569
6A
S13
Pocalla
4.8
4.8
Bermuda ass Hay
'5.6
Tons
311.9/30
• 275
0
0
Irri .
275
109.8
0.0
529.1
0.0
34569
6A
S13
Pocalla
4.8
4.8
Small Grain Overseed
1.0
Tons
10/1.3/31
50
0
0
Irri .
50
20.0
0.0
96.2
0.0
34569
6B
S13
Pocalla
1.9
1.9
Bermuda ass Ha
'5.6
Tons
3/t-9/30
• 275
0
0
Irri
275
109.8
0.0
205.3
0.0
34569
6B
S13
Pocalla
1.9
L9
Small Grain Overseed
1.0
Tons
1011-3/31
50
0
0
Irri .
50
20.0
0.0
37.3
0.0
34569
7A
S13
Pocalla
3.0
3.0
Bennudagrass Hav
05.6
Tons
3/1.9/30
* 275
0
0
IfTiL
275
109.8
0.01
334.8
0.0
34569
7A
S13
Pocalla
3.0
3.0
Small Grain Overseed
1.0
Tons
10/1-3/31
50
0
0
Irrig.
50
20.0
ul
60.9
0.0
34569
7B
SD
Pocalla
4.7
4.7
Bermudagrass Hav
'3.6
Tons
3/1.9/30
' 275
0
0
Irriz
1 275
109.8
O.ol
517.1
0.0
34569
7B
813
Pocalla
4.71
4.7
Small Grain Overseed
1.0
Tons
10tl-3131
50
0
0
Irrig,
50
20.0
0.0
94.0
0.0
34569
8A
S13
Pocalla
4.71
4.7
Bermuda ss Hay
15.6
1 Tons
3/1.9/30
" 275
0
0
Irrig.
275
109.8
0.0
517.1
0.0
34569
RA
S13
Pocalla
4.71
4.7
Small Grain Overseed
1.0
Tons
1011-3/31
50
0
0
lrri&
50
20.0
0.0
94.0
0.0
34569
8BI
S13
Pocalla
2.9
2.9
Bermuda ass Hav
'5.6
Tons
3/1-9/30
' 275
0
0
Irrig.
275
io9.8
0.0
319.4
0.0
34569
813
S13
Pocalla
2.9
2.9
Small Grain Overseed
1.0
Tons
1 1011.3131
50
0
0
1 Irri .
50
20.0
0.0
57.91
0.0
34569
9A
S13
Pocalla
4.6
4.6
Bennuda ass Hav
15.6
Tons
3/1-9/30
• 275
0
0
brig.
1 275
109.8
0.0
509.4
0.0
34569
9A
S13
Pocalla
4.6
4.6
Small Grain Overseed
1.0
Tons
1011.3/31
1 50
0
0
Irri .
501
20.01
0.0
92.6
0.0
34569
9n
S13
Pocalla
4.3
4.3
13ermudn ass Hav
'S.6
Tons
3/f.9/30
1" 2
51 0
D
Irrig,
275
109.8
0.0
472.1
0.0
34569
913
S 13
Pocalla
4.3
4.3
Small Grain Overseed
1.0
Tons
10/1-3/31
1 501
0
0
lrri .
501
20.0
0.0
85.8
0.0
Lagoon Liquids
Total Applied,_] OOGallons
14,830
Total Produced, 1000 gallons
12,574
Balance. 1000 gallons
-2.256
Manure Solids
Total Applied, tons
0
Total Produced. tons
0
Balance, tons
0
Notes: 1. In the tract colunum, s�inbol - means leased. otherwise, owned.
2. Symbol ' means user entered data,
... . _................................................................................................................................................................................................................................................................................................................................._...................
805126 Database Version 1.05 Date Printed: 05-09-2001 WUT Page 3

The Irrigation Application Factors for each field in this plan are shown in the following table. Infiltration
rate varies with soils. If applying waste nutrients through an irrigation system, you must apply at a rate
that will not.result in runoff. This table provides the maximum application rate per hour that may be
applied to each field selected to receive wastewater. It also lists the maximum application amount that
each field may receive in any one application event.
Irrigation Application Factors
Tract
Field
Soil Series
Application Rate
inches/hour
Application Amount
inches
34569
I
Pocalla
0.60
I. 0.12
34569
IOA
Pocalla
0,60
O. 2
34569
LOB
Pocalla
0.60
1 0,12
34569
1 11
Wagrarn
0.60
0.
34569
112
Wagrarn
0.60
0.7
34569
l3
Wa am
0.60
0.7
34569
14
Wa m
0.60
0.7
34569
15
Waa am
0.60
0.7
34569
16
Wam
0.60
0.7
34569
17
Wa m
0.60
0.7
34569
18
Wa am
0.60
0.7
34569
19
Wa m
0.60
0.7
34569
2
Pocalla
0.60
0,
34569
20
Wagiram
0.60
0.12
34569
21
Wagram
0.60
0. 2
34569
22
Wagram
0.60
O. 2
34569
23
Wagram
0.60
0. 2
34569
24
Wagram
0.60
0. 2
34569
3
Pocalla
0.60
0. 2
34569
4A
Pocalla
0.60
0. 2
34569
4B
Pocalla
0.60
0. 2
34569
SA
Pocalla
0.60
0. 2
34569
513
Pocalla
0.60
0. 2
34569
6A
Pocalla
0.60
0. 2
34569
6B
Pocalla
0.60
0""2
34569
7A
Pocalla
0.60
o.
34569
7B
Pocalla
0.60
0.
34569
8A
Pocalla
0.60
0.
34569
8B
Pocalla
0.60
0.
34569 19A
Pocalla
0.60
0.7
34569 19B
Pocalla
0.60
0.
....... -- - -- .........................................
805126 Database Version 1.05 Date Printed: 05-09-2001 1AF Page I

The following Lagoon SIudge Nitrogen Utilization table provides an estimate of the number of acres needed for
sludge utilization for the indicated accumulation period. These estimates are based on average nitrogen
concentrations for each source, the number of animals in the facility and the plant available nitrogen application rates
shown in the second column.
Lagoon sludge contains nutrients and organic matter remaining after treatment and application of the'effluent. At
clean out, this material must be utilized for crop production and applied at agronomic rates. In most cases, the
priority nutrient is nitrogen but other nutrients including phosphorous, copper and zinc can also be limiting. Since
nutrient levels are generally very high, application of sludge must be carefully applied.
Sites must first be evaluated for their suitability for sludge application. Ideally, effluent spray fields should not be
used for sludge application. If this is not possible, care should be taken not to load effluent application fields with
high amounts of copper and zinc so that additional effluent cannot be applied. On sites vulnerable to surface water
moving to streams and lakes, phosphorous is a concern. Soils containing very high phosphorous levels may also be a
concern.
Lagoon Sludge Nitrogen Utilization Table
Crop
Maximum
PA-N Rate
Ib/ac
Maximum Sludge
Application Rate
1000 gallac
Minimum Acres
5 Years Accumulation
Minimum Acres
1 10 Years Accumulation
Minimum Acres
15 Years Accumulation
Swine Farrow -Finish Lagoon Sludge - Standard
Corn 120 bu
150
13.17
174.021
348.04
522.07
Hay 6 ton R.Y.E.
300
1
26.341
87.01
174.02
261.03
Soybean 40 bu
14.051
163.151
326,291
489.44
_.._....................................-................. .................. ,.......... ,... _.... ...,_.- ............. ..... ............. _....... ...... ............. ......... .
805126 Database Version 1.05 Da1c Primed: 05-09-2001 Sludge Page I

The Available Waste Storage Capacity table provides an estimate of the number of days of storage
capacity available at the end of each month of the plan. Available storage capacity is calculated as the
design storage capacity in days minus the number of days of net storage volume accumulated. The start
date is a value entered by the user and is defined as the date prior to applying nutrients to the first crop in
the plan at which storage volume in the lagoon or holding pond is equal to zero.
Available storage capacity should be greater than or equal to zero and less than or equal to the design
storage capacity of the facility. If the available storage capacity is greater than the design storage capacity,
this indicates that the plan calls for the application of nutrients that have not yet accumulated. If available
storage capacity is negative, the estimated volume of accumulated waste exceeds the design storage volume
of the structure. Either of these situations indicates that the planned application interval in the waste
utilization plan is inconsistent with the structure's temporary storage capacity.
Available Waste Storage Capacity
Source Name
Swine Farrow -Finish Lagoon Liquid
Design Storage Capacity (Days)
Start Date
1 9115
180
Plan Year
Month
Available Storage Capacity (Days)
1
l
73
1
2
60
1
3
62
1
4
68
1
109
l
6
151
1
7
192
1
8
233
1
9
226
l
10
210
l
11
190
1
12
164
* Available Storage Capacity is calculated as of the end of each month.
............ ..........
805126 Database Version 1.05 Date Printed: 05-09-2001 Capacity Page

Required Specifications For Animal Waste Management
1. Animal waste shall not reach surface waters of the state by runoff, drift,
manmade conveyances, direct application, or direct discharge during
operation or Iand application. Any discharge of waste that reaches surface
water is prohibited.
2. There must be documentation in the design fold that the producer either
owns or has an agreement for use of adequate land on which to properly
apply the waste. If the producer does not own adequate land to properly
dispose of the waste, he/she shall provide evidence of an agreement with a
landowner, who is within a reasonable proximity, allowing him/her the use
of the land for waste application. It is the responsibility of the owner of the
waste production facility to secure an update of the Nutrient Management
Plan when there is a change in the operation, increase in the number of
animals, method of application, receiving crop type, or available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs
for realistic crop yields based upon soil type, available moisture, historical
�. data, climatic conditions, and level of management, unless there are
regulations that restrict the rate of applications for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre per
year. Waste may be applied to land eroding at more than 5 tons per acre
per year but less than 10 tons per acre per year provided grass filter
strips are installed where runoff leaves the field (see USDA, NRCS Field
Office Technical Guide Standard 393 - Filter Strips).
5. Odors can be reduced by injecting the waste or by disking after waste
application. Waste should not be applied when there is danger of drift
from the land application field.
6. When animal waste is to be applied on acres subject to flooding, waste will
be soil incorporated on conventionally tilled cropland. When waste is
applied to conservation tilled crops or grassland, the waste may be
broadcast provided the application does not occur during a season prone
to flooding (see "Weather and Climate in North Carolina" for guidance).
7. Liquid waste shall be applied at rates not to exceed the soil infiltration
j rate such that runoff does not occur offsite or to surface waters and in a
.............................. .......................
805126 Database Version 1.05 Date Printed: 05-09-2001 Specification Page 1

method which does not cause drift from the site during application. No
ponding should occur in order to control odor and flies.
S. Animal waste shall not be applied to saturated soils, during rainfall
events, or when the soil surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner
that the crop is not covered with waste to a depth that would inhibit
growth. The potential for salt damage from animal waste should also be
considered.
10. Nutrients from waste shall not be applied in fall or winter for spring
planted crops on soils with a high potential for leaching. Waste/nutrient
loading rates on these soils should be held to a minimum and a suitable
winter cover crop planted to take up released nutrients. Waste shall not be
applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with
the following: The outer perimeter of the land area onto which waste is
applied from a lagoon that is a component of a swine farm shall be at least
50 feet from any residential property boundary and canal. Animal waste,
other than swine waste from facilities sited on or after October 1, 1995,
shall not be applied closer that 25 feet to perennial waters.
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other
than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and public
right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways,
or wetlands by a discharge or by aver -spraying. Animal waste may be
applied to prior converted cropland provided the fields have been
approved as a land application site by a "technical specialist". Animal
waste shall not be applied on grassed waterways that discharge directly
into water courses, and on other grassed waterways, waste shall be
applied ar agronomic rates in a manner that causes not runoff or drift
from site.
. .. .. ...... ..... .... 1.1....................
805126 Database Version 1.05 Date Printed: 05-09-2001 Specification Page 2

16. Domestic and industrial waste from washdown facilities, showers, toilets,
sinks, etc., shall not be discharged into the animal waste management
system.
17. A protective cover of appropriate vegetation will be established on all
disturbed areas (lagoon embankments, berms, pipe runs, etc.). Areas
shall be fenced, as necessary, to protect the vegetation. Vegetation such as
trees, shrubs, and other woody species, etc., are limited to areas where
considered appropriate. Lagoon areas should be kept mowed and
accessible. Berms and structures should be inspected regularly for
evidence of erosion, leakage, or discharge.
18. If animal production at the facility is to be suspended or terminated, the
owner is responsible for obtaining and implementing a "closure plan"
which will eliminate the possibility of an illegal discharge, pollution, and
erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected
( on a regular basis to prevent breakdowns, leaks, and spills. A regular
maintenance checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other
crops for direct human consumption. However, if animal waste is used on
crops for direct human consumption, it should only be applied pre -plant
with no further applications of animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and bottom
elevations of the temporary storage (pumping volume) of all waste
treatment lagoons. Pumping shall be managed to maintain the liquid level
between the markers. A marker will be required to mark the maximum
storage volume for waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested
at least annually at crop sites where waste products are applied. Nitrogen
shall be the rate -determining nutrient, unless other restrictions require
waste to be applied based on other nutrients, resulting in a lower
application rate than a nitrogen based rate. Zinc and copper levels in the
soils shall be monitored and alternative crop sites shall be used when these
......................................................... .... ... ....... ........................... _... ..... ............... ........ ....... - ....... .......... ........._.
805126 Database Version 1.05 Date Printed: 05-09-2001 Specification Page 3

metals approach excessive levels. pH shall be adjusted and maintained for
optimum crop production. Soil and waste analysis records shall be kept
for a minimum of five years. Poultry dry waste application records shall
be maintained for a minimum of three years. Waste application records
for all other waste shall be maintained for a minimum of five years.
23. Dead animals will be disposed of in a manner that meets North Carolina
regulations.
.......................................................... ..
805126 Database Version 1,05 Date Printcd: 05-09-2001 Specification Pa e 4

' i {}�. r uhr. y, ,�,I �.�,�.ry-'. {t •::{r.i i- • 1il '� '1�N'<
- v..., 4' w I�,fU'� tis. r � ,ier i � : � f�•.'i :; `;•''-. �i, � , L �' "nl
,,,A, K�ti✓ "�•y.: "; l'i.4.1�1;"`�r`�. :,,r,�rt 4r 1. M1Si(:'l,i�• ^1�.W CY '��l -;'l'• '�� rn -ry .. ��/�.'�-'�
. � :1.TA•` t r,. r 4 -.e' J r .j' pJ, JrtS � • � ,�,��':�...'�` }
its
1 fit'
J:` ",7.-�;.?,«.;�,� _,�'"'�,�i'�, r �?�•�. '�rQ. ii.� ;�;y?,;`: .;t , JJ
r "rN. t t ,.�i;'�.�'•- elf
c,},, ((' r
•f Jlj,'r•e ' %` 7 -•�': i�i •l ::`;^ J:% UP
• ,
AQ
!h ` f�" '� -1,S ';+jt,•7' .� �� : � �•. 1y+, y'!�, ., 4 •�.�" �. #� r'*:.' .rr 'C�-^••1 * ,,,,,~t,�--� r». m<r �-n•}.,ri'; : �'i�i,•'•..r �!�`;' w
,•�:'P�. � -''�l�i"'!�i` ��:,: �' �ir',�rsti'" �tr.-_ti.:A .'' 'i.'. ��];T`r:;n,:� �•6L`fa;>1n `yr � 't "y�I
• � ; �} c:'� ` 'iati x•�t. � Y � ; .-c k t'!rii-.•tH .i aji,: y r ...'r.`.-i 't. ; r,� `t top,
�• :'�'• .:::,,� � 1• •�' r `
' r+r•' Y � = ��•2�.t..:. ,.: ti.�. ,�� g - '+=�•t/�.-„i r'A� ...�M ,,,'t.r.,: _ - �, • " sis; ,� ' J •'�ii: +:r -•ji i ,y
�'� ''x � .K.�,� r f:.'•r1• IJ. f••.Sr 2•d '�,
•.�,. ,{' �'�'e.�0.r..: .'"�.J ,-e c,rr•i)-..s, a', ;�,: ,�;xw i^_-ya .1�r,�,!Y: •'Yil; r.!••'':z �Ai:��,f-t,. .,1'�►,F�•,• °„�:s: •."!`��y7� .f9•+�-.,
�• ,�, w:i•. ,,�. �: �': '�-i?fY•"=- ^y C�; i -�.� -�G"�'• fL-va^.J:'RJ. �"�i.�
••r• l ! 7rs J�, ,�� Y` i ti.r 1jj1yy��..��ss����aaaa �: � d, r>'y"•„Yy +•- }` � �
.1. ^;{• "!� f A }, T;,� i-'"�sl+"•'r,L�.R� � r„ y l�` � W ?f • y_Ti,r,,,.d•,i�#.+ Y,K��•a1} - ,,gyp .
,•'r'..• :_,r #; ��J. •'•�,r ..t .r.'� •;'*ram"' ' '� „••'N+!, ': .;�';o.L+� .a , t :�.,
�� / .,�r� ,_, � w'��.,-\�'r: J e.r _ . •'a...% ��., ,qt' ,d.s-.. j: •• 1 -�-.� 't r/.+ �'� y. �,•�k',N
.{i�•; i,; ^7:. r �'. .+.� y, a: �,�"�;�-, tr:.':.• t .�. i, '".-G'il•..',•:;,.- "a:i..� r. .n,j1 �"� ''�
;••,,., ,: h'.: !,•,.:. a„_:,r. r.S,.,r: - k:`r.,.• :� i i.,'7 - K'.F%is• l�'!S .;r,�'j'•'i�Y"9... M1 t�y•
��•'• 7 �. 'd .,• .w, " •�; t•3, � ,r.i• ,!,t j-•`,•:.l^•)�wi a, •:'.; i': r'••; tv'i1�• ,.y=S t1r�•.•.-'•{'{` J� .i
r!,'6 j1`.J'.+,. �, a .t lcs' .�*•'�' .;.!?�:�' � ,�: i• r�J ��• - t.�., .:'Y - '• .,.• may: .; � �,.;�' :��
iK �, � � r •., - , .:a' Y• iv.r+Jti".•w 3�';'.`a:3' � 7' ��i tl' 7'.•
t �)• / �••.ht. � �,.�,�. r'� � .r}. 'irS r.%..� +, •..� � z, -.�' � r,J,. s•„3•r,%'�:1a'. 7 1 .�
s,•: Si I+y�Si C''r Sa �r .iL J.'Y+('�i- } r• ��:
J �.1/1 -L .11.F .`,! .,-I;.-�•'+,:.%. ,::�:FI•, ,�t�F. J r�a. r• J� '111
•r a.=.si �'J •� �s' R:ir� ;11•:y:ti:.'i�•r�i',; ;... .. 1� ['_�✓''�W �e s ',�:1,` ii
wy ., yi,i �a•L 1 `r.1• ' ,�.�•_..i �. /1ryy .. x �.r1- p..,,r•
r J;1 �' F i .. J;''�} f•-'�.a� I ti f...a�.-..:J,y; ,• } '�, .�91
•,?:+yt':.'.'„Zr � i"M 1.^,a � w� v `w:-•f,.. �, a�'Ct��. .. t•,'S '• rr.-.
�,t �. -. -{ r '� :�• •��!•,F �, •, � ram= � Krr'.
�,.\��'FF�.1"''fir' '�a X'•, l;.fi.....��`.�r '�• Ill,1-'.s.�, ��,ly ";
,�, �}7.V f ��,} > ! hrti� F .�IIFJ� z � ti- 'S y".y�h,1„}t ;l �j r�• iJ ,, '► Fitt
I' T r a` • ) liar *ti„-� :. Yr_ 1 siiy -tr; � "? p. .�. � �••+)rZ
�5 '.i..: '• S {. '.J 4 Lt1 .- .1. f,, .t� x � :';, *• t, :'- • + .t�_ �J rT. . R�:
.�1°':* =;}� ,Jai: ; ,, ;.%.'.; "' '.^..•_.r.�°.:Y,,, ,1'i' .a,",.'��; ;,,. ":Jl 'I ' s-�}�
��.;..1,, :'�+�:•' o, r;. :7. r. _. �. �',-- lr.l,,.�:15`TT�.•-�;: r':.+. '- r„tf�� „ ��.
E ::& .".r-r'�"�-•r '��?.:� •'.-y r , ' �,'a'r',:, r4 F, . �4 f 1• �Tp r•T`� ''t � ..w > i �}••,t_c
t s J ,r , sJ'± _,�', 1�r�'..':�•Irr�ri:a� r,s�.� " art:.} �yyy - •:rry_ .} _ .ti'. ��
Jl �,[, a � � , '.�t�r. - -r Via`✓ i1 tr r � ti'�� Yi,i•.�"�tz l � - �j n� �r in ti4, �P ;+,�� i" :� ' • '�•'`�'�•'. - v _ ! Y�;
' r1 �-+ y •r'r l r % c : i :L' } r . __� �y"'-'' 4
fti"•:Si} :},a. r�!!.'r 1 /.�.sl ��.>:�_�;' :>.'; ,,;, :/�lar°�� t MIX a�r, ��':::i� �.�'...•. �� -- f:v; � F, I. d .I .� rt.na
:a r y. s J ..- •-J F �!v Lr. r'ls'}� r ' �n,.aN:.' �•,..• `�. 't.4 -. �. ;S :=1 w.=
•v: ..r 4J) `r' ,f .a r. !:-r ,.}' t''„1•'-r ` �F`•.i i ±. 1: .•r.:.'! t dam,✓
,rtsd ,21''•'.�.s r: .7.. it . y. c-j'f•7.-.�
! ft '•�- � t._ 1^4'_•_'i. a�,,.+C �1: .J
w .i r 1Jr.•., ..t. tr _ ) t•p..c': :6 •l`1..' l
,•► f:' ,•I.t• _ a�.- '�i`- :.ir �• '�1.,iiay`�'_,.;.--1�.:•L' `� .�`" - 6.1'" J 'e+.y � �y'r'• + :1�i..
:�'^i .2: •�'�! �4•1�}�, ;"' FYI'','' m .w. 3'.•'j• ?.. ��, :.��.:!:r `�-; i :..Yr"�'i� i' _ �;� �.
,r�Ki•r.. j"t'�,.�.;j'y't�.a%};:-! JK �:I; M' .:.1�:'�t;� 1l. :.� .•,Aw' �=tom •�,;,ry.iS. N��. �,'a.. `'r; .y:'►'�%ii ^''� +,
J „YJTj; ir, �srl ia:i ., J.' '. ;y,.::%-. : � .ti �3 .4 "`• '�/itr';', � it 3'F r'y..l_;.v'�'� ..,� �-,K}'Y.A K,�h:: �r •r�` n •�i;�l
J, r.:;'f:'+•,L.1 „•`' y• :•Y +'�j4 i'. fi ,, n a'."\ `:r ;,r^ "v...� l-'r =M1..�, ;.'f'W�'t1 ' , , �,: ''''-:�1`� , 1 i/+'Iia.1 ., '.;lf '.f ''''''i".
+�, ! � .'::• . � _ ,! t � r- r 1 �'• . �.�., y y1• 7 .. 4 1„ rr �F" r ,� S' v .,,��•
,•• .�:} '`',J.c.�J• • rl , t •.e.C�;:•`;.:a �,,•^ �. ± .w.. 4i.'. 7,.t.. i •4h� ��*,�i' �•� .lJti J,..,' *�.+y
'. J:y. �'12ti'..1 rti., ryi91%if. f .;,Jrr�.'•�ti ,. ,�,• tf;.f�r: 'cj-,; '�,:�• + ,µ;:, r. �';r qr tt��i-r .q,4-4Vd-
.�: xy_ +'SI'tip .f :..��,' }�- r• vT
r"J•,•'••}'^''��r�y�'=:ir3�P"':J; ��f.-j ir' i C"i'ti ;1 ,,,.7��d ,3yam�. r •.`'.�• �{: S.:Y711}•. ,�. �;1u
} h y 3 .1S`• - r�� ' i •'� W V. - r � „ � ,ylytt1•' � �'r.1 y, • / f
?;s4r•rJ;✓.';•�7��}fifr;yl:,,`,}`'�r ji'it'•'•` Jr•��- i,3 r _f r� u e_� J�..;� �, �jt.,,•�•, ` °�Jt��_^Y- 4 �'•
!.t l f •�i ,•�J=i . j :.vr JJ.' � /p a i' ;s. J. . r•. �f•- • �; `'�+i •.
i r r St ,r.r' �!• •'. .,,, 1 ' h, ''J' 1 -t ✓ :.' a �i'�'' �t J .S.�.q A t' ,� 4 J �{ i-"I %aS•!'•. �
r; �J,'.j)�; :a. �.}f 4 � . ?r `tir%•.. �,' 7-e .'F�:+ L/ es'�'r� r.}�,(, �+� •r .. K l•' Q }.f�ti 1:;•�4.� j:. � ��•�'
:i �'i rrnr �1.•..i '..�{•�;.i, �T:ry`U:JS'�'; .:�:�✓.�•, �'�t��•',. s�.N _f'''kk�Y r�%�}"iH .a'•'�'s,. r��'�;'r.1�tis.:��. +��'Vr�+ S��
�,ti',•� .�� ':'yYr'f �'!.•t'..i' '�';�i,,;i`i 'f.�' :r`' t•n'.,: �.;r, k. r� ,`' •1 a.�;�eii ��:•,�+tia 't+. J �, b'
� JJ t.rJl •.1�a'"{r j� J f,� ., j._,�,'i:l:�' ",'. R V `;,.. �•?. ';y� �(1S ..,c t L'?}1'{' ,S
S r`. �3 f';.; ''., ; i. r� i � •. r ? T t i i„! r . r . • .}�, i • r. ,:�, ... , w V,�. } •� "t. � v , r 4 -
�, l iti
�: �w dr l ' :.1 a. J rr "•r.� r� , 1a��- tl,,••,�„-,t;'':'...` t�C�:.!.t
a.r 7f y 1� "i
�a 1, wits (.;1� ':i; i�taFJ': ��:%,+ ::rr•.tl a��`�a<2 •• Jr.•a ,ti L+iii�r.. 1.• r ,"�•
j• i � sh r .l' � . ^ f`::` :;,�.r f ��;/, -a'i �� ,+T J'• d•'.� y � L C'
'1.L"^ 7„.r�C ,4`� r• 'rt �t 1J
;J loss K S 1•"A ,i3{.'+.J3.tf S':f j'aPs [%•• W��,"
•i.iyy �' 1 !,•: 1r.�3
t.i''7 J Vi,. �i,'�.N, . ,,3,�i• M{•.� '•!, r ,�` '." a�� :G
Iltt :,l�F:e� ,i �p,�►,7.•rY . 4{* _ •7:,i2"nl'` •}• ,Z; _• �?i.}1:� ;e?nr`ii�'i4
SP. :ttl4 �l:.. ��.: ys�+�.l ,�y(. ,.f �r :i14' t`r.r •,l',-?�,r �`�r1�NN•=3:n, r rt=' � J" , ay;Iwi� i{I-�1•`•v.'Sr`-%,+�'.�a••�� "
p��Tr rY �` St. , � ..�"t'"�Zr �•-.r,. �f � +'x:'�i�.�•��-v�b`��1+9 T�J�'> �
ypo
t��, � ��`�: . , .-. : ..1�.. �'y t„;,•h„• ,'s1,�n�;r`y,r �y!{ ;�t r'yw.� i .; ir.'y.,��
.r• .r'' • i'k F '� s. :. �':.. y iy. �tJ h' rj•t ^!�f/a• :_ d.1rJa3` .rjj•
• �,. ',�t� �` � � ' � •� .�,,f•yr1;t �yr7i r-• nAl:1^•
'" �`... w; ,�.-��;4'�S•ri r-'��,I! Ii ,.. �r'�lr�� �a'SI';,k l�d.' 1*+yi •R:f. 'J.,: w,
•r�, Jl�•� •i't: �, •.}.I'fa�,Y •tl •,i•?'1�. �,.� '� .fir *. �. �T��. �;7 l��r� /�.. F'•j/!.

LAND LEASE AGREEMENT
This land lease agreement is entered into this 1st day of
March 1992 by and between Betty Smith DuRant_
(Landlord) of 12520 Cotton Drive,Laurinburg,_ NC 28352_ _ _. and
Carroll's Foods, Inc._ (Tenant) of Warsaw, N. C.
1. Real Property: Located in Alfordsville Township, County of
Robeson State of North Carolina, being known and more particularly
described as: 49.39 acres of cleared farm land as shown on the attached
ASCC field map_(outline in_red). Said parcel is a portion of the 97_acres
tract described in the Robeson County registry in Book 171 page 163
Legal Description- see Deed reference
2. Personal Property: None
3. Term of Lease: The term of this lease shall be for 20 years
from March 1 , 19 92 to March 31 , XM 2012
4. Rent: The Tenant agrees to pay to Landlord the following rent: $30 per
acre ver Year for the first 10 wears and $39 Der acre ner Year for Years 11
through 20 year 1-10 rent will be $1481.70 per annual
Year 11-20 rent will be $1926.21 per annual
Rent to be paid on the anniversary date of this lease
5. Tenant's intended use: The property shall be utilized for agricultural
uses only. Said agricultural uses shall be determined at the sole discretion
of the Tenant. Tenant agrees to maintain said property in a responsible and
workmanlike manner and shall keep property in as good condition as at the
beginning of the lease term. normal Wear, depreciation, and damages from
causes beyond Tenant's control excepted.
b. Landlord's access to Property: Landlord shall have the right at all
reasonable times to enter the leased premises and inspect same and to make
such repairs to buildings and improvements as Landlord may deem necessary for
the preservation of the leased premises. Any and all improvements or repairs
deemed necessary by Landlord and made by Landlord will be at the sole expense
of the Landlord.
C00101070370

7._Tenant Improvements: The Tenant may make improvements to the property
at Tenant's expense. These improvements may include installation of under-
ground irrigation pipe and fencing for grazing cattle. The Tenant may at any
time prior to the expiration of this lease or within a reasonable time there-
after, remove such improvements provided Tenant leaves in good condition the
parts of the farm from which said improvements are removed.
B. Tenant_ _Covenants: Tenant convenants that he will not use said premises
for any purpose other than farming, hay production, cattle grazing, or other
such agricultural uses as Tenant deems necessary. Tenant will not use the
premises for any unlawful purpose.
9. Remedies in the event of Default: If Tenant is delinquent rA
days in the payment of a rental installment or if Tenant should breach any
convenant contained herein, Tenant shall be in default of this lease and in
such case Landlord may re-enter the premises and reclaim possession. Landlord
shall provide written notice to Tenant of Landlord's intent to reclaim posses-
sion.
in. Option to Extend: Tenant shall have the option to extend the term of the
lease for an additional ten year's to commence upon the expiration of the ini-
tial term._ Rent for said _extension will be S50.70 per acre per year. All _
provisions of this lease shall apply- to the extension provided for by the op-
tion. Tenant shall notify Landlord in writing no later than 30 days prior to
the end of the initial term if Tenant intends to exercise the option to extend
the lease term. - T
" 11. Additional Provisions: (1)_ Tenant will not knowlinnly allow on
F the leased Rremises during its tenancy. (2) This Lease may not be assigned
or transferred to others without the approval of Landlord.
12. Possession: Shall be delivered upon execution of this Lease.
13. Counterparts: This Lease shall become a binding contract when signed by
both Landlord and Tenant. It is to be signed in two counter-
parts with a signed counterpart being retained by each party hereto.
As witnessed by our hands:
(SEAL) Date
Witnessed by
(SEAL) Date
Witnessed by
tSEAL) Date
Landlord
(SEAL) Date
Landlord's Spouse
(SEAL) Date
Tenant
C00101070371

p
lof
'Its
0
.3 i

t State of North Carolina COPY
Department of Environment, Health and Natural Resources
® Division of Water Quality
. Non -Discharge Permit Application Form / Survey
a (THIS FORM MAY BE PHOTOCOPIED FOR USE AS AN ORIGINAL)
F;
L 1 f eneral Permit - Liquid Animal Waste Operations
following questions have been completed utilizing information on file with the
ikon. Please review the information for completeness and make any corrections
r which are appropriate. If a question has not been completed by the Division, please
complete as best as possible. Do not leave any question unanswered.
Application Date: Li-Z.3 In --
I. 'REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item
Aplicants Initials
1. One completed and signed original and one copy of the application for General Permit - Animal
Waste operations;
2. Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is disposed;
3. Two copies of the Certified Animal Waste Management Plan (CAWMP). If the facility does
not have a CAWMP, one must be completed prior to submittal of a general permit application
for animal waste operations.
II. GENERAL INFORMATION:
1. Farm's name: 7572
2. Print Land Owners name: Carroil's Foods Inc.
3. Land �OO � Ses Mailing address: PO Drawer 856 _
City: i2+eW4?Pd NC Zip: 28398
Telephone Number. 210-293-3434 _
4. County where farm is located: Robeson
5. Farm Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a copy
of a county road map with the location of the farm identified): _From Rowland take 501 North at Raem-on and tuIM L--t,on
R 1131 and proceed R 1102'1 n theAn road
farm is I mile on the LL
6. Print Farm Managers name (if different from Land Owner): Lr--l E= —SA V 4S
7. Lessee's / Integrator's name (if applicable; please circle which type is listiZd): �waa,�[i�s i`oAdrn . Zjc-
FORM:-AWO-GE 2/26/97 Page I of 3

III. OPERATION INFORMATION:
1. Farm No.: 78-12
2. Operation Description: Swine
Farrow to Finish
12W - Certified Design Capacity
Is the above information correct? Q y s; 0 no. If no, correct below using the design capacity of the facility
I= of Swine Tyne of Poultry No- of Animals Tyne of Cattle No- of Animals
0 Wean to Feeder
0 Feeder to Finish
0 Farrow to Wean (# sow)
0 Farrow to Feeder (# sow)
0 Farrow to Finish (# sow)
0 Layer 0 Dairy
0 Non -Layer 0 Beef
0 Twkey
Other Type of Livestock on the farms: No. of Animals
3. Acreage cleared and available for application: _; Required Acreage (as listed in the CAWMP): 118
4. Number of Lagoons: I ;'Total Capacity: 3.. 15 �� D 15 Cubic Feet (ft3)
Number of Storage Ponds: • 0 ;-Total Capacity: Cubic Feet (ft3)
5. Is animal waste being applied on any field which has subsurface drains? YES or (please circle one)
6. Are subsurface drains present in the vicinity of or under the lagoon? YES or (please circle one)
I V . APPLICANT'S CERTIFICATION:
(land Owner's name listed in question 11.2), attest that
this application for S l m n jt,-�, _" Wl lL IZ 15— (Farm name listed in question U.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be:re me as incomplete.Signat44
Date -13 --
V . 'S CERTIFICATION: (complete 'oniy if different from the Land owner)
(Mlanagees name listed in question I1.6), attest that this
application for (,�A"OL('S mgi� '�5' T'l (Farm name listed in question IL1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be returned as incomplete.
Signaturedn 1, Y Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
PERMITS AND ENGINEERING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FORM: AWO-G-E 2/26/97 Page 2 of 3

"-:r%:�1ti t.
�`�".
s - �.
'.iC"E.1 . ., '` is iY ;".� .!
-
� •, .• �.i
ri•:Cr :�'.
� �
..r,...
'f 'Y�+7�! r '"�ra�a: •i.��. S � y��
'i��(: i '::ry J :� t����. -�'. .
�
�.
i+•�•
O
CAIOIf � �f
q
d dTJMWIT
w
NUT
•'�••
: o
ooe
�,
C�; •�
,�.
. ,' �
lip
�� ?�':
. 1
� •moo' � l
�
�'�0.:;
wrP • ' ! � '�:�':'�'+ =d•
Y
wr �
��
4�
.. may.
�•
�
��sy
'' -
'taw.
-•
lb
,
• ,
IM�'
I�
iL

s�
ANnVLL WA5T8 XAHAGMM-?T PLAN CERTIFICATION FOR EXISTING FEEDLOTS
Please return the completed form to the Division of Environmental Hanagement at
the address on the reverse aide of thin fora.
of farm (Please print) : Ldeeoi)'s !-ovri5 , I i-C *- 757Z
M3 �:zg ACare s :
Phone No.: -
i% Co
yq� f farm}
rk� location: Latitude and Longitude J � /0 � (required). Also
a attach a copy of a county road map with location identified.
of operation (swine, layer, dairy, etc.) : T.. 1 Ne _
D,j;sg5n capacity (number of animals) : dD -
Average -size of operation (12.month population avg.): ob
Average acreage needed for land application of waste (acres):
a aaaaaaaaarsaacaaa�aaagaasa�aasaasasaaasaaaaasaasaaaaaaaaaaaaast--pxa��sasssaaaaaa,F'
Technical Specialist Certifications
As a technical specialist designated by the North Carolina Soil.. and Water
Conservation Commission pursuant to 15A NCAC 6F .0005, I certify that the
existing animal waste management system for the farm named above has an animal
.+aste ruaiiaycluerit Palau that r,aetm the ^._ =Moon and an
specifications of the Division of Environmental Management and the USDA -Sail
Conservation Service and/or the North Carolina Soil and Water Conservation
Commission pursuant to 15A NCAC 2H.0217 and 1SA NCAC 6F .0001-.0005. The
following elements and their corresponding minimum criteria have been verified
by me or other designated technical specialists and are included in the plan as
applicabld: minimum separations (buffers); adequate quantity and amount of land
for waste utilization (or use of third party); access or ownership of proper
:waste application equipment; schedule for timing of applications; application
_ates; loading rates; and the control of the discharge of pollutants from
stormwater runoff events less severe than the 25-year, 24-hour storm.
Name of Technical Specialist (Please Print) : dw,"D L• �r93o�r
Affiliation (Agency) : 1_7AW1W.i fps _72rG
Address: & %CA�WA 05-6, LL9itJjMd ./I-C• Phone No.9/D 29.�q-r393¢
Signature: _ Y�:/Lya� _ Date: 4,
-:assaaaaaaroaasaasaaRasaasaaaasrsaMraaaasasaaaasaa3aa7ac�aaaaaaaaa=sar..a
Os�ner/Haaagar Agrsamaat
(we) understand the operation and maintenance procedures established in the
approved animal waste management plan for the farm named above and will implement
these procedures. I (we) know that any expansion to the existing design capacity
of the waste treatment and storage system or construction of new facilities will
require a new certification to 'be submitted to the Division of Environmental
Management before the new animals are stocked. I (we) also understand that there
must be no discharge of animal waste from this system to surface waters of the
srace either directly through a man-made conveyance or through runuZZ %rota n
storm event less severe than the 25--year, 24-hour storm. The approved plan will
be filed at the farm and at the office of the local Soil and Water Conservation
District.
Name o f
(Please Print] :
Signature: Annv=�& IT
(I i5A,54
:Name of HAMAger, if d'ff r t f
Signature:
r-t
Date • IO f�`-7
owner (Please print) : Nrrll FLIT tQ S l�t-
Date: 1,
Hote: A change in land ownership requires notification or a new certification
(if the approved plan is changed) within 60 days of a title transfer.-
DEM USE ONLY: ACEii

UNITED STATES
DEPARTMENT OF
AGRICULTURE
soil 4405 Bland Road Suite 21.0
.-'Conservation Raleigh, North Carolina 2-7609
-service Telephone: [phone]
Subject: ENG-Swine Waste Management Date: February 12, 1991
Class V, Carroll's Foods, Inc.
Mason Farm -Robeson County, NC
To: Billy Jones, Civil Engineer File Code: 210
USDA -Soil Conservation Service
Goldsboro, NC
The subject swine waste management system is approved as per our
conversations and correspondence.
Please advise if we can be of further assistance.
Harry J''-. Gbs'on y' '
State C.onservation Engineer
cc: David A. Combs

r
-UNITED STATES SOIL FEDERAL BUILDING, ROOM 116
DEPARTMENT OF CONSERVATION 134 NORTH JOHN STREET
AGRICULTURE SERVICE GOLDSBORO, NORTH CAROLINA 27530
TELEPHONE: [phone]
------------------------------------------------------------------------
SUBJECT: ENG - Approval Request for Class V DATE: January 7, 1991
Lagoon
TO: Harry Gibson, State Cons. Engineer FILE CODE: 210
SCS, Raleigh, NC
Attached is a Class V lagoon design for Carroll's Foods, Inc. for your
review and approval.
The lagoon location has been shifted since the soils investigation July
12-13, 1990. The present location is still within the area
investigated, but a liner should not be required. If any clean sand is
exposed during construction it will be removed and backfilled as
recommended in the attached report.
A small area (less than 0.5 acre) will need clearing in the southeast
corner of the designated building area.
Since the revisions in nutrient loading requirements, the owner has
adequate land for control grazing or range grazing.
If you have any questions or additional information is needed, please
let nee know.
Billy H. nes
Civil Engineer
Attachment
CC., David Combs
V

! OPERATION AND MAINTENANCE 4 '7
Tgis lag_or, is desi;ned for waste treatment wi h minimum 'odor
contr.D I . The time required for tree planned f I ui d level to be
L reactied may vary due to soiI conditions, flushing operations, and
the amount of fresh water added to the system.
Lane application of waste water is recognised as an acceptable
method of disposal. Irrigation by Center pivot, solid set or
traveler is the preferred and most efficient method to dispose of
the effluent from the lagoon. Care should be taken when applying
s waste to prevent damage to the crops and to prevent runoff from
the fields.
The following items are to be carried out:
1. Begin pump -out of the lagoon when fluid level reaches invert
of the outlet pipes or at a pre -determined elevation. 101.3
L. Stop pump -out before the lagoon depth is less than 6 feet
deep or at a pre -determined depth. (This prevents the- loss of
favorable bacteria) q 8. O`arw_ 1'1!' f'..S Ji,•✓
�
�Pro>
e :. .
3. The recommended amount to apply"per irrigation is one inch,
and maximum recommended application rate is 0.5 inch per hour.
�gssltrt.. proPsr.+ op�-�':ffon ate. d ��
4. It is recommend that the treatment lagoon be precharged to
1/Z its capacity tdeprevent excessive odors during beginning
stages of the operation. Precharging reduces the concentration of
the initial waste -entering the lagoon thereby reducing odors.
Solids should be covered with water at all times.
5. Keep vegetation on the embankment and areas around the lagoon
and buildings mowed.)
6. Repair any eroded areas and establish in vegetation.
T. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Natural Resources and Community Development (ONRCD), Wastewater
Management Section, has the responsibility for enforcing this
I aw. .
Ie. All surface water is to be diverted from the lagoon to an
adequate and stable outlet.
CERTIFICATION:
I hereby certify that I understand the operation and maintenance
requirements stated above. Furthermore, I understand how many
acres are required in order to land apply the waste and that
the lagoon may have to be pumped Z or more times a year. This
design has peen explained to me and I agree with all provisions
stated in the design. I also certify that there are no residence
other than mine or my tenants' within 750 feet of this operation.
I understand that climpliance with this design DOES NOT prevent
someone from suin�.' ne because of nuisance or other reasons.
Signature---------------------------------- Date -----------------

t
WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land
application. Any discharge of waste which reaches surface water is prohibited.
Illegal discharges are subject to the assessment of civil penalities of $10,000 per day
by the Division of Environmental Management for every day the discharge continues.
2. The Field Office must have documentation in the design folder that the producer
either owns or has long term access to adequate land on which to properly apply the
waste. If the producer does not own adequate land to properly dispose of waste, he
shall provide NRCS with a copy of a written agreement (sample enclosed) with a
landowner who is within a reasonable proximity, allowing him/her the use of the land
for waste application for the life expectancy of the production facility. It is the
responsibility of the owner of the facility to secure an update of the Waste Utilization
Plan when there is a change in the operation, increase in the number of animals,
method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for
realistic crop yields based on soil type, available moisture, historical data, climate
conditions, and level of management, unless there are regulations, that restrict the
rate of application for other nutrients.
4. Animal waste may be applied to land that has a Resource Management System
(RMS) or an Alternative Conservation System (ACS). If an ACS is used the soil loss
shall be no greater than 10 tons per acre per year and appropriate filter strips will
be used where runoff leaves the field. These filter strips will be in addition to
"Buffers" requried by DEM. [See FOTG Standard 393 -- Filter Strips and Standard
390 (Interim) -- Riparian Forest Buffers.]
5. Odors can be reduced by injecting the waste or disking after waste application.
Waste should not be applied when the wind is blowing.
6. When animal waste is to be applied on acres subject to flooding, it will be soil
incorporated on conventionally tilled cropland. When applied to conservaton tilled
crops or grassland, the waste may be broadcast provided the application does not
occur during a season prone to flooding. (see "Weather and Climate in North
Carolina" in the Technical Reference -- Environment file for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
runoff does not occur offsite or to surface waters and in a method which does not
cause drift from the site during application. No ponding should occur in order to
control conditions conducive to odor or flies and provide uniformity of application.
5

WASTE UTILIZATION PLAN
----------------------
1=Aa+nv%- if- 7S I) -
Owners name--:CARROLL,S FOODS INC. County:ROBESON
Mail Address-:P.O.DRAWER 855, WARSAW, N.C_28398
Type of production unit----:FAR-FIN
Number of animal units-----: 1200
Type of waste facility -----:Anaerobic Lagoon
Temporary storage period---: 180 days
Method of application ------ :IRRIGATION
Amount of animal waste produced-----------------: 23932 tons/year
Amount of plant available N produced by animals-: 44400 lbs./year
Commercial N to apply on planned acreage--------: 0 lbs./year
Your animal waste utilization plan has been specifically
developed for your swine operation. The plan is based on the
soil types, crops to be grown, and method of application for
your particular operation. The waste must be land applied at a
specified rate to prevent pollution of surface and/or ground
water. The plant nutrients in the animal waste should be used to
reduce the amount of commercial fertilizer required for the crops
where the waste is to be applied. This waste utilization plan
uses nitrogen as the limiting nutrient. Waste should be
analyzed before each application cycle and annual soil tests
are encouraged so that all plant nutrients can be balanced for
realistic yields of the crop to be grown.
Several factors are important in implementing your waste
utilization plan in order to maximize the fertilizer value of
the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the
needs of the crop to be grown and the nutrient content of the
waste. Do not apply more nitrogen than the crop can utilize.
Soil types are important as they have different infiltration
rates and leaching potential. Waste shall not be applied to
land eroding at greater than 5 tons per acre per year. Do not
apply waste on saturated soils or on land when the surface is
frozen. Either of these conditions may result in runoff to
surface waters. Wind conditions should also be considered to
avoid drift and downwind odor problems. To maximize the value
of nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or
not more than 30 days prior to planting. Soil incorporation
of waste will conserve nutrients and reduce odor problems.

10
c
_ . Page 2
The acres needed to apply the animal waste is based on typical
nutrient content for this type of facility. Annual acreage
requirements may be more or less based on the waste analysis
report for your waste management facility.
YOUR WASTE UTILIZATION PLAN IS BASED ON THE FOLLOWING:
Tract
Field
Soil
Crop
Yield
Lbs. N
Acres
Lbs. N
Month to
No.
No.
Type
Code
/Acre
/Unit
Used
Apply
0
0
0 A
0
1.60
0.0
0
S-APRIL
0
0
0 A
0
1.60
0.0
0
S-APRIL
T34569-
7
PoB
L
N/A
133.00
11.6
1542.8
S-APRIL
T34569
6
PoB
L
N/A
133.00
31.7
4216.1
S-APRIL
0
0
0 A
0
1.60
0.0
0
S-APRIL
T34569
7
PoB
C
5.5
50.00
11.6
3190
MAR-OCT
T34569
6
pob
C
5.5
50.00
31.7
8717.5
MAR-OCT
0
0
0 A
0
1.60
0.0
0
S-APRIL
T34569
6
PoB
L
N/A
133.00
6.0
798
S-APRIL
T34569
5
WaB
L
N/A
133.00
5.0
665
S-APRIL
t34569
5
PoB
L
N/A
133.00
15.0
1995
S-APRIL
T34569
4
PoB
L
N/A
133.00
8.0
1064
S-APRIL
T34569
4
WaB
L
N/A
133.00
7.0
931
S-APRIL
T34569
3
Ly
L
N/A
133.00
3.7
492.1
S-APRIL
T34569
3
PoB
L
N/A
133.00
10.0
1330
S-APRIL
0
0
0 A
0
1.60
0.0
0
S-APRIL
T34569
3
WaB
L
N/A
133.00
20.0
2660
S-APRIL
T34569
6
PoB
C
5.5
50.00
6.0
1650
MAR-OCT
T34569
5
WaB
C
5.5
50.00
5.0
1375
MAR-OCT
T34569
5
PoB
C
5.5
50.00
15.0
4125
MAR-OCT
T34569
4
PoB
C
5.5
50.00
8.0
2200
MAR-OCT
T34569
4
WaB
C
5.5
50.00
7.0
1925
MAR-OCT
T34569
3
Ly
C
5.5
50.00
3.7
1017.5
MAR-OCT
T34569
3
PoB
C
5.5
50.00
10.0
2750
MAR-OCT
T34569
3
WaB
C
5.5
50.00
20.0
5500
MAR-OCT
--___
-----
-----
-----
-----
-----
Total
-----
236.0
-----
48144
------
Available
Nitrogen
(includes commercial)
44400
Surplus Or
Deficit
-3744
Crop codes:
Crop -unit
A=Barley-bu.
B=Bermudagrass(graze)-tons
C=Bermudagrass(hay)-tons
D=Corn (gra in) -bu.
E=Corn(silage)-tons
F=Cotton-lbs. lint
G=Fescue(graze)-tons
H=Fescue(hay)-tons
I=Oats-bu.
J=Rye-bu.
K=Small grain(graze)-acre
L--Small grain(hay)-acre
M =Sorghum (grain) -cwt.
W=Wheat-bu.
Y=Fescue(pasture)-tons
Z=Bermudagrass(pasture)-tons

Page 3
If more commercial fertilizer is used than shown in this plan,
then additional acres of land may be needed. A three to fifteen
feet wide permanent grass filter strip should be seeded along all
ditches in fields that receive animal waste.
Additional comments:
--------------------
Prepared by: :aa Title: - Date:
* � y42Pot1s *cc.
Concurred in by: Date:-f~i5
Producer
I understand that I must own or have access to equipment,
primarily irrigation equipment, to land apply the animal waste
described in this waste utilization plan. This equipment must be
available at the appropriate pumping time such that no discharge
occurs from the lagoon in a 25-year 1--day storm event. I also
certify that the waste will be applied on the land according to
this plan at the appropriate times and at rates that no runoff
occurs.
Date:
Producer
Technical Specialist: 4a,-)aL ), Date: r-r-95
(Copy to producer and copy to case file)

2
ATTACHMENT A
Page 1
WASTE UTILIZATION PLAN
Producer C'a fir, s: c County IV
n•
Address
Address
Kind of Operation._lo.ye. Soul
T� f%visfi Type of Waste Facility �A 60 oAP 4�
Your animal waste management facility has been designed for a
given storage capaciy . When the waste reaches the designed
level, it must be land applied at a specified rate to prevent
pollution of surface and/or ground water. The plant nutrients
in the animal waste should be used to reduce the amount of
commercial fertilizer required for the crops on the fields
where the waste is to be applied. This waste utilization plan
uses nitrogen as,the limiting nutrient. Waste should be
analyzed before each application cycle and annual soil tests
are encouraged so that all plant nutrients can.be balanced for
realistic yields of:the crop to be grown.
Several factors are:important in implementing your waste
utilization plan'in order to maximize the fertilizer value of
the waste and to ensure that it is applied in an
environmentaliy'safe manner. Always apply waste based on the
needs of the crop to be grown and the nutrient content of the
waste. Do not apply more nitrogen than the crop can utilize. -
Soil types are important`as"they'-have*-dif-ferent'infiltration
rates and leaching potental., Waste shall not be applied to
land eroding at greater than 5 tons per acre per year. Do not
apply waste on saturated soils or on land when the surface is
frozen. Either of these conditions may --result in runoff to
surface waters. Wind conditions should.also be considered to
avoid drift and downwind odor problems. To maximize the value
of nutrients for"crop production and to reduce the potential -
for pollution, the waste should -be applied to a growing crop or
not more than 30 days prior to planting. Injecting the waste
of, _diskf!hg' will- aorlsetve ,nutrients-' and' keduca .-ddok. =ptobl6ins .
The acres needed to apply the animal waste is based on typical
nutrient content for this type of facility. Acreage
requirements may be more or less based on the waste analysis
report from your waste management facility.
The design of your waste management facility is based on the
following:
ount o �als
e oduced Pe Year:
/oo= an x/ 9waste /animal/yr �:� 9`/2 Y�'total waste
i 3 s- produce

B�rk�t's 71ve L!e- sho•rs
ATTACHMENT A
Page 2
Amount of NitrQaen^d Per Year:
i o 0o animals x � lbs N/animal/yr 3;L o 0 o total N
3 9 9G, oro
Applying the above amount of waste is a big job. You should
plan time and have appropriate equipment to a the waste in
4_timely mannar. Your facility is designed for /8 o days of
storage. Therefore, it will need to be pumped every
months.
The following acreage for waste application will be needed
based on the crop to -be grown and surface application:
fig � soii ' crop talistie !!s. M Acres LSe. M Ronth of
-Typo - Tleld Per Ac. Rr/i.� a4S J( Utilized Application
60 q
/M~°R
!
-71.z
19 lv
ZZI b
.+
3-Ar
dal.0
s
++
3 z
O
TOTAL
Anxm of N /roAxed
surplus await
oo v
8C=� o
Narrative yf Operation
(V . o8lAc/Rwl..s /JIr /, raw soap: B/ A', rs-t UP a— %
Jp�1i,S,ErO tra.TiQirlyr LoRd,�.C+�Af�S /ncT. lg4�,=,i A�nx iveo X� o,Q/ _ d�/ B,t,ess
EJ��..-r.Ba[ GtA?_;�d,_,,•,��c,a�una ,p��.�. �.:A . �„ r�.��r,yv1 L��_s /ao .�+c��s
4'R3 T'w cA X / O/d Cares = /00 Ac_ t ate.
Call the Soil and Water Conservation District office after you
receive waste analysis report to obtain the amount per acre to
apply and the irrigation application rate prior to applying
waste.
Prepared by 0>'te_ fI/• V'94""� 7
ame Title wDate
Concurred in by
Producer
(Copy to Producer and copy to case file)
Date
� �.�.��•.a -� o ,�� ��o/e ,!s � d � - Ct v`y s �i'�� f%�"�i°����,+�,��s
9 wsz r.� �rct.
p�

C
�_ �,�,�,, t �� MAY i 7
1990
-NC-ENG-24 U.S. Aop.rtnont of Agriculture
8 /72 Sol! Conserr.tfon Service
(formerly NG7100)
\i Request for Engineering Assistance
NAME Carroll Farms/Robeson Co.
VORK UNIT Lumberton F. 0. ©besoh
TYPE OF JOB
Drainage: 0. D. Tile Pump Group
Farm Pond: Stock Water Irrigation Fishing & Recreation
. M.
Excavated
Irrigation Terracing Striperopping Grassed Waterways
Lagoon X other
WORK M BE CHARGED TO
CO-1 X REAP Watershed:
WE OF ASSISTANCE REWESTED
1. Needs and feasibility X 5. Layout Assistance
2. Survey Assistance
b. Constr. Supervision
3. Design X 7. Final Check
fit.. Design Approval 8. Other
Estimated job class: I II III (IV) (V) ;� 7 _),z _ 90
DATE ASSISTANCE REWESTED 5/23-24/90
RC&D :
We have a request for a design for a 1000 sow, farrow to _
oi3eration. It has been some time since a design
of this magnitude has been requested. We need a refresher
course in lagoon design for this particular case. I have
discussed this need with Billy.
OF
902Lj�%.., 49Aot 12N,0 Q2' G'an��ITi�n�� D/ram User
TH DaJ/�/�,E'TTi"�S'-.z'q _90 _ C97e I-i --,-rPk-AZ1A .4"W /0l-9Jr/6Arr
.4-G A / ,r�l�L AG.o.�N�7/y1i� riDJ A�?
DATE: 1 APPRDVT-Z_�
WWK4 can..e.rr. ,nw un
�aysI p4ou7 S�-,vF0 /f jwo k;e G. --Oo
istrict Conservatio _st
p�0
( Area Conservationist) y.

i
l PUnited States
Decartment of
• t. - Agriculture
Sad
Conservation
Service
l
OPERATOR:
Please review the attached plan and specifications carefully. Retain
this plan for your use and records. It is strongly recommended that yau,
your contractor, and Soil Conservation Service personnel are in agreement
as to how the waste lagoon is to be constructed. The Soil Conservation
Service personnel will meet with all concerned parties and walk over the
site to explain all flags and markings. It is important that everyone
understand what is expected so that final construction meets plans and
specification and the sob can be certified for payment (if cost -sharing
Is involved).
The pad $3mensions and grades are the best estimate. The BUILDER or
CONTRACTOR is RESPONSIBLE for final layout and design of the pads. The
Soil Conservation Service personnel will assist in a limited capacity,
as its major concern is the*proper design and construction of the waste
treatment loon.
The actual amount of material required for pads and•dam may vary from the
estimates. The design will attempt to balance cuts and fills as close as
possible. If additional material is required after construction is complete
on the lagoon, the contractor and owner will negotiate.on the price and
location of borrow area.
NOTE: Design Requirement: 2 6o9o72-cu.ft. - cu.yds..
Estimate of Excavation: J o {[ u.ft. - 6�6 Zcu.yds.
Estimate of err 0ike:` tuft. - / 7Z u.yds.
Ration Y�Lar,
Job Class
Date
Designed By ,
e
Design Approval
N m
I _
a te
itfa&W Conswvafron Sanwce
VJis an agormy W to
GaOWMM"t of Agncumo*

OPERATION AND MAINTENANCE
This lagoon is designed for waste treatment with rninimum _.d0r-
control. The time required for the planned fluid level to be
reached may vary due to so i I conditions, flushing operations, and
the amount of fresh water added to the System.
Land application of waste water is recognized as an acceptable
method of disposal. Irrigation by center pivot, solid set or
traveler- is the preferred and most efficient method to dispose of
the effluent from the lagoon. Care should be taker, when applying
waste to prevent damage to the crops and to prevent runoff from
' the fields.
The following items are to be carried out:
1. Eegin pump -out of the lagoon when fluid level reaches invert
of the outlet pipes or at a pre -determined elevation.. 1 0/-3
?. Stop pump -out before the lagoon depth is less than 6 feet
deep or at.a pre -determined depth. (This prevents the loss of
favorable bacteria) 9 810
S. The recommended amount to apply per irrigation is one inch,
and maximum recommended application rate is 0.5 inch per hour.
: 4. It is recommended that the treatment lagoon be precharged to
1/Z its capacity to prevent excessive odors during beginning
stages of the operation. Precharging reduces the concentration of
the initial waste entering the lagoon thereby reducing odors.
Solids should be covered with water- at all times.
5. Keep vegetation on the embankment and areas around the lagoon
and buildings mowed.
6. Repair any eroded areas and establish in vegetation.
7. The Glean Water -Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Natural Resources and Community Development (DNRCD), Wastewater
Management Section, has the responsibility for enforcing this
law.
G. All surface water is to be diverted from the lagoon to an
adequate and stable outlet.
CERTIFICATION:
I hereby certify that I understand the operation and maintenance
requirements stated above. Furthermore, I understand how many
acres are required in order to land apply the waste and that
the lagoon may have to be pumped 2 or more times a year. This
design has peen explained to me and I agree with all provisions
stated in the design. I also certify that there are no residence
other than mine or my tenants' within 750 feet of this operation —
I understand that compliance with this design DOES NOT prevent
someone from suing ne because of nuisance or other reasons.
Si3nature-__-___----_Date

a -C?
Animal waste lagoons are designed with permanent storage
(waste treatment volume) and temporary storage.
The designed 6 month temporary storage is an estimated
volume based on: 1) waste from animals; 2) excess rainfall
after evaporation; and 3) the largest 24 hour (one day)
rainfall that occurs on the average of once every 25 years.
The volume of waste generated from a given number of animals
will be fairly constant throughout the year and from year to
year. The excess rainfall will vary greatly during the year
and from year to year. This estimate is based on T inches
of excess rainfall which is equal to or exceeds the highest
6 months excess ,in a year. The average annual excess
.rainfall is approximately 8 inches. Therefore, an average
of 8 inches of excess rainfall will need to be pumped each
year. The 25 year rainfall will not be a factor to consider
in an annual pumping cycle, but this storage volume must
always be available. A maximum elevation is determined in
each design to begin pumping and this 'is usually the outlet
invert of pipe from building(s). If the outlet pipe is not
installed on the elevation to begin pumping, a permanent
marker must be installed on this elevation to indicate when
pumping should begin. After initial filling of lagoon, a
minimum 6 feet depth must be maintained for anerobic
treatment of waste. An elevation must be established to
stop pumping to maintain the minimum treatment depth.
Pumping can be started or stopped anytime between these two
elevations for operating convenience so long as site
conditions permit (conditions are weather, soil, crop, and
equipment to apply waste to prevent runoff or leaching).
For this lagoon the maximum elevation to begin pumping is
/D1.3 feet and the m i n i mum e 1 evat i an to pump to i s _?Afftpfeet.
The design temporary storage,. less 25 year storm, is ACo 6 9/4(
cubic feet or 7 4tIIons. As stated before, this volume
wi l l vary con idefably from year to 'year.
This lagoon is designed to flush buildings with recycled
lagoon liquid, and fresh water should not be used for
flushing after initial filling.

ATTACHMENT A
Page 1
WASTE UTILIZATION PLAN
Producer C'd"j2/-1-S rooasap /NC County )6423Z.
Address
Kind of Operation /000 Soe!J
/591?e,p e4J Zip F/ /.Sfi� , Type of Waste Facility Z-A611 .v � I-AAvo 1¢�. ICA
Your animal waste management facility has been designed for a
given storage capaciy . When the waste reaches the designed
level, it must be land applied at a specified rate to prevent
pollution of surface and/or ground water. The plant nutrients
in the animal waste should be used to reduce the amount of
commercial fertilizer required for the crops on the fields
where the waste is to'be applied. This waste utilization plan
uses nitrogen"as the limiting nutrient-. Waste should be
analyzed before each application cycle and annual soil tests
are encouraged so that all plant nutrients can be balanced for
realistic yields of the crop to be grown.
Several factors are important in implementing your waste
utilization plan in order to maximize the fertilizer value of
the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the
needs of the crop to be grown and the nutrient content of the
waste. Do not apply more nitrogen than the crop can utilize.
Soil types are important as they have different infiltration
rates"and leaching potental.'Waste shall'nat be applied to
land eroding at greater than 5 tons per acre per year. Do not
apply waste on saturated soils or on land when the surface is
frozen. Either of these conditions may result in runoff to
surface waters. Wind conditions should also be considered to
avoid drift and downwind odor problems. To maximize the value
of nutrients for crop production and to reduce the potential
for pollution,'the waste should be applied to a growing crop or
not more than 30 days prior to planting. Injecting the waste
or disking will conserve nutrients and reduce odor problems.
The acres needed to apply the animal waste is based on typical
nutrient content for this type of facility. Acreage
requirements may be more or less based on the waste analysis
report from your waste management facility.
The design of your waste management facility is based on the
following:
Amount of -Waste Produced Per Year:
1 ovo animals x � 9reu waste /animal/yr = / 9 90 o to�'t
lotal waste
produced.

` ATTACHMENT A
Page 2
qV,4/e, 4TL.,5
Amount of Nitrogen Pro-d- r Per Year:
/.o a o animals x _a6lbs N/animal/yr total N
Applying the above amount of waste is a big job. You should
plan time and have appropriate equipment to apply the waste in
a timely manner. Your facility is designed for 1 8o days of
storage. Therefore, it will need to be pumped every s-EE
months.
The following acreage for waste application will be needed
based on the,crop to be grown and surface application:
Field soil Crop Restlstic Lbs. M Acres Lbs. M Month of
Type Yietd Per Ae. Utilized Apptleation
- ~/�iCftLeo�
C
o L
9,.312
O
T
0AL
7z0
FIQL OS
'
TOTAL �'Q o
-m Mt of N °
surplus or Deficit
0
26 o O¢
Narrative- of Operation
I-!
Call the Soil and Water conservation District office after you
receive waste analysis report to obtain the amount per acre to
apply and the irrigation application rate prior to applying
waste.
Prepared by
Wfime Title Date
Concurred in. by
Producer
(Copy to producer " copy to ease file)
0
Date
474,
J
'BcrTj r

gl�
'.. _ `tom

U. S':.Department of Agriculture
Soil Conservation Service
HAZARD CLASSIFICATION
NC-ENG-34
September 1980
File Code: 210
DATA SHEET FOR .
Landowner C o -,Q24,rg f'4'R County
ol
Community or Group No. Conservation Plan No.
Estimated Depth of,. Water to Top of :Dam / 3 'Ft. Length of Flood Pool 70 0 Ft.
Date of Field Hazard Investigation
Evaluation by reach -of flood. plain :downstream.to ".the.point of estimated minor effect.
from sudden dam ,.fai:lure.:
• ;: Est.
Elev. s Elevation
.Kind of '. :Improvements: -of Breach
Reach: Length:..wi.ath:: ,Siope:-'i Land Use :::: Improvements Above :Floodwater Above
: Flood Plain: Flood Plain
Ft.--.. Ft. : 7+: • . :. .-Ft.. Ft.
3
Describe potential for loss of life and damage to existing or probable future downstream
improvements from a sudden breach
=�a0-IM62,Ay __ N �� %S o�oT�Nr� � 1�� s.o e_ , oc?_.C? s►c
r Qa rr „ sr,P A)o /,A"Q.LdQ ASe. , ,g
vAr
Hazard Classification of -Dam a b, c) (see NEM-Part 520.21)
"I'491,lassification (I, II, III, IV, V)
By
name
e
Concurred By
name title
NOTE: 1. Instructions on reverse side.
2• Attach additional sheets as needed.
Date / -Ze- o
Date

5-
U. S. DEPARTMENT OF AGRICULTURE
'Soil Conservation Service
N p? d�
-3417S.!
W 41rY
�ar9�
J>J�be
EARTHWORK COMPUTATION SHEET
EARTH EMBANKMENT
NC-ENG-12
Rev. 6/82
Name (ft91f/�¢LMA X&I.c! /Po 9= Sa on/(/rye I/,
Address
Embankment: Top Width ' Side Slopes .12- r,,/
STATION
FILL
HEIGHT
( Feet)
END AREA
(Sq. Ft.)
SUN OF
END AREAS
(Sq. Ft.)
DISTANCE
( Feet)
DOUBLE
VOLUME
( Cu. Ft. )
D f•oo
o,
4 ,c�
/�d
/o
1f3a
> `
2-/oD
-zo o
0
xtso'
s'.o
/
z
4 t so
5 f
3
3
/ d
�fGb
121 if/vim
e7 7.30
7�
/DZ�
7
otZs
�-
S98
/oo
?,CIO
/ fzs-
a
2-
17,26
C7
O
o .�
Co
a ar'�JGC
�/(g w/
$ • TTA� Ar
S/4
44c./Ci/c 4
w�T G S
h•+ w TiE� AL .
M .�R�o"v A
s.�
FRG
1. lib W Volume of Filler-= �L,r.� e/ /,�_ Cu. Ft ir- 7Wi-s 8+,4-
o�
2. Volume of embankment fill (line I t 27) /L• 7 93 Cu. Yds.
3. Allowance for settlement {3. 10% of line 2) _ / G 7 9 Cu. Yds.
4. Total cubic yards (line 2 + line 3) _ / gy 7 Z Cu. Yds.
y Computed by . f • Date

s�A 17' v44Af
61 FZ. /03
R&A /9 T
;za7Y
/moo Yf
3`2 •�,r� ov X Ioo _ 3�z000 j Ts
.01
S�3o 3
�,�Soo f s9�o K ra a 6-2 3,0 a cp
z
.6�.1-40 142A0,4 ,Q7 41"t400 15--940 1-'-7"
�li� cuT 4S AT 3 f 5-1; lf- eev N Tv F %o
_ y
-.�/✓D '/9�PEA /T.j .jl> oo /-,eon ,F 1' 7- To G Ca //to a fT
.Z X !o -o - r 3f3 -7 �T3
X e4 4 A r
�•�- t�ssn
�-- - X/ o v Z7
Z.
.�r✓,U i9�E_A I T Z -too / 5 ,S o c %i'
iy yo
19,d I
i Y Z.
0
,�.7Xz•2s.ss
L
A, /1 reg .a r / t / 6 � 3 3 0 � S,CS,2J 3 2. � r'T 3 �,Qc a ✓ �Xc
7'v TA L C 4 !/ATi o N 3 1r Al- f 7-3 =- --5 6 7.2 YD 3

r
%4

' 1 -
f o 4'EF r
f� /Qo, ri � I '�•I�q� �f'f _ � [ , : irt�\� 'r r :
-
C/? J'OL. LDS - Mt95'ON FARM `7-
/000 SOW FRyfR0W - FINISH
ROBE501V CouffTY, MC
i f. S. 17EPAF FIVIC:NT OFF` n( "t11C U1ATUl:t l

AF'A" I-C
•
6� bo
V
-
-
�
--- . . _..._....,.
�...... __ -
-IPiir -
- . ___„_._ .. ..., :..._.." .. //�jY.-. _...... -. ,may_ ..
... ...--__.. .._... -..... _._ . .,.... _ .. .
.. -.:
: ..
._:,: ... �
: ; •.. .:.:
......- ..,_..: '.. .....Tg'/C.a ..... /lam_.
. ., ..�� .-... 9�. ..... ., .. . . �. .:T. •.. : . : :.
97
P.5,00 • ro fygApisr
—
F---3;IZlt1.A. ---- —._� : �_ ..::_.�.;::: -- - - -• _...�...
...... _.........___--- ....... ._._.., ."::�. •.-- •CcT.r.4.1".� .�...-•---'---..� ,'- -:- • _ .� _-
�� _ _-�—_..i3S.�•i' �. V?_.�s;i__—_._,_.t��bc� - _.�...._�_�p.�a�.___._..-..eN47...._—_�e.'�a8_-..� T.__--'--�4iy�__r-�-- ...__.-._ ....—
J_ o -
T
__ . ....�... __.affEll
._..... _ __ - _ ILL-- - - F
-yam I:� �"
ooi?..:x_lylti:".c��.x�fif/.T.D:t?o:.LGL:--._._._,._______�-••_wry;* -.. ._-•� --•' --- ...... _`:�:._.,�. __.__.-_. .._'�•_.. ----,-r----•--•- ----.... ___ --� ---.._—._ __.. __. _-=
P__QE_.P1J�F...'¢E�. .(a3.Q _—__ • .�45L -_!PO• — _ "- —
r�-:_ �:'M_—.�ta3.1-:•---_::7��:3:.�_�a�:7-�.���...�—,_1o7.C._'---�os:g._...__�.`�9.2
/3o rr_F.f►9:AELFY :._ __..... y M ..... _.. T: ;:_:.
..:..—::-
-
•yveoas
0PbR'RR .y .-,S.TorPRG�IBp
�AS7►E�T%.00a ��`fs'�a�S7Ayii=37?r�f.�- ----- �-- ' -- Lp/'L__:.C�9:tF
xs Jy-Clt�r tTot/n��6.7) wo.frr it7r,�._• _... ! 2 _ ...
�� '"lirr = G/SB3 wT �'

B4 -
' O •-�'- _ .._... .. _. ... . ._. ..___.._. _�.: ..:.-- --Y• -----..^. ..:.. ':. :.�.:' � � _ �: :.. .,::.: . . � 'ram _ _. - ... ._�...
d �-
- L.. ►
_
I y, ;
46
_
IF
-44
c
___ _ •— — _ _ a _ —
a.. ..ST.�.._._... __-Vtk._._.. _
- ..
.. . . _ _ . . . .
f
- Z
to �.. h
n d a
iW

1�2.7 loG.�
ce
G`r
/.03. t ...
2 faa 4err
_!�S ._. �'_.. _. .....----•-....__.---___:__.. . � � _ _.�5=_ � •:ado....... _ _ :...:�-- -..._.._ .. _.. ._. _ ...
.__ .._Sr��Oi.�C' -.SPA-�; -_.. _ ..,.... •--_.... .......__.
10RN��
54rfa /a %5 Cov,.,tsrwv ai,eiNe-o/i G.t3',,' !'6d 7c,c't
N...3'rn n < < G �k �✓ Mc,.A G k
SFC�lE_jyj�Mctv
ir.CG`T/./�LftEIC z=/. �i�►,c.4A�.�CrYrc/�iE��.
t 4

/oE`f�. :�''I 1y•e.'htt� �y}/7�7�h� 'rJ �.:, i!+f I ,!� aI � � � T !. ' {i,!�.
Tee P#T/"-o f7-!Vb
'X, Ir
. ..... .....
SIP j
it 3r
f* rill ILI
ct-*3 ix
-2-7: A) a --w j�ri 7Y�Ak
C:C rz4 > :tg> .7
7r, r, 4z 4
EA.;
Ij
rd
*q i Pi Sty 42'�'r,
:. -
be
�4
r i;W-r- -1-4--
6 240C r lop.
7*15
-
'7-,, 7-AZ- j 2>410i 7.
... .... .. . ..
ac r ido&49ow; v.,, re, 4 r �.O,x:xNw oitn
4�
ivei
. . . . . . . . . . . .
:n x
I's c S1-
Fix
P: iwi J5 r0,, pwr�,t
Z"L -
jr
1
llil� L
sdn: SA
wo
G4r,--4y;
lruAJ
I
V9,
Opvnf,< 1 j4o 4Cqd"l f"
z-r/ IV
Al 40-
;e 19A'6i1 AMA)
: m m : , .
err. (P r P`i
Rc 4 6,10t;
osa)
4.:

UNITED STATES soil 4405 Bland Rd., Suite 205
DEPARTMENT OF Conservation Raleigh, NC 27609
AGRICULTURE Service (919) 790-28.86
Subject: ENG-Soils Investigation, Date: August 13, 1990
Carroll's Foods, Inc. AWL,
Robeson County, North Carolina
To: Billy Jones, Civil Engineer File Code: 210
Room 116, Federal Building
134 North John Street
Goldsboro, NC 27530
PURPOSE•
To conduct a soils investigation and assess the site
conditions for construction considerations.
DATE•
July 12 and 13, 1990
PARTICIPANTS•
Ed Holland, District Conservationist, Lumberton, NC
David Hedgpeth, Soil Conservation Technician, Goldsboro, NC
Billy H. Jones, Civil Engineer, Goldsboro, NC
Kim G. Kroeger, Geologist, Raleigh, NC
INTRODUCTION•
Carroll's Foods, Inc., recently purchased this tract of land
to locate a 1,000 unit hog operation. This project is
considered a Job Class V lagoon. The engineering job
approval authority is with the State Office. The lagoon
will be mostly an excavation type and a dam safety permit is
not required. If the lagoon's dimensions change and the
embankment height is over 15 feet, then a permit will be
needed.
The site is located in the Southern Coastal Plain Land
Resource Area of North Carolina. The topography of the area

is nearly level to gently sloping. The lagoon is located
adjacent to the side slope to the Big Shoe iieel Creek. See
Figure 1 for a topographic map of the site and area.
According to the published soil survey for Robeson County,
the soils in the area belong to the Wagram soil series and
the Pocallo loamy sand. The Wagram loamy sand mapping unit
is considered well drained and very deep. The Pocallo loamy
sand is considered excessively drained. Both of these soils
have formed in coastal plain deposits. See Figure 2 for a
soils map of the lagoon area.
NARRATIVE'
Six (6) test holes were excavated to investigate this site.
See Figure 3 for a plan view of site and location of
borings.- See the attached log of borings for a detailed
description of each test hole.
Generally, the soils consist of a thick surface layer
composed of silty sands (SM) and clean, poorly sorted sands
(SP-SM). The surface layer is about 2 to 4 feet thick. This
surface layer is underlain by a very slightly to slightly
plastic clayey sand (SC) or a silty sand (SM) subsurface
layer underlain by layers of nonplastic silty sand (SM)
subsoil and plastic sands (SC) and clays (CL, CH). See
Figure 4 for profiles of borings in lagoon area. In places,
the subsoil contains layers of clean silty sands (SM) with
an estimated 15 to 25 percent fines.
The Goldsboro Area Office has two (2) options for the lagoon
dimensions. See Figure 3. Option 1 has a bottom elevation
of 90 feet. option 2 has slightly larger dimensions and has
a bottom elevation of 92 feet. See Figure 5 for a fence
diagram of the lagoon area. Both options expose silty sands
(SM) below elevation 94 in the southern part of the lagoon.
See Figure 6 for possible areas of silty sands (SM) exposed
in the planned lagoon bottom elevations of 90 and 92 feet.
These areas were estimated by the test pits excavated in the
lagoon area. Other clean sandy areas may be exposed during
excavation.
INVUMM
There appears to be little difference between Options 1
and 2 in the amount of sands exposed in the lagoon bottom.
Both lagoon bottom elevations of 90 or 92 feet would expose
silty sands in the southern end of the lagoon pool area.
Any clean sandy areas exposed in the bottom should removed
and backfilled and compacted with a clayey sand (SC) soil.
The clayey soil blanket should tie into clayey residual
soils.

The sandy (SM) areas should be over excavated and backfilled
with at least two (2) feet of plastic soil. The soil
blanket should be applied in three (3) lifts and compacted
with a sheeps-foot roller between each lift. Each lift
should be 8-inches thick.
Each 8--inch soil layer should be compacted to 95 percent
standard Proctor (or a minimum of six passes with a sheeps-
foot roller) at a moisture content equal to or greater than
optimum.
A nonplastic silty sands (SM) surface soil layer is present
in the lagoon area. This soil layer contains an estimated
15 to 25 percent fines. This layer is 2 to 4 feet thick. A
core trench under the embankment should extend through this
unit.
After excavation the lagoon bottom should be disked and
compacted to break up any soil structure and disturb any
root channels. Disking and compacting the bottom should
reduce the initial permeability and speed the sealing
process.
Cut slopes and embankment slopes should be uniform.
Kim G. Kroeger
Geologist
cc: Ed Holland, District Conservationist, Lumberton, NC
Harry Gibson, State Conservation Engineer, Raleigh, NC

Q��or�s ragas . rnC-
.
July 12, 199
vests atari KGK I e, Geologist
{ t
Hand Auger SaCIci16E
n:
<•••. Site Olstributlon ....
t '
Interval
t ee t)
•M
+r
4
+M
�r
Y
%
o /, S
1°_1�
most
—
-
��
Llw.ic.
GI. J
—
i, .0
hoti,,,
„un
.5. �.y
rs-La
rru5i
1,
r.n
d
kQ".4,
0)0--,
rre
br-r.0
dr
n.4
hero
it
/r"Krj iL
Test Role Ro.: Station: 4 i 70 Elevation; .5- Water iebtf Elevation: after hours.
Sa 7o
Le h,t_
Sheet r of

r
Q ~ . 1 •
But

Frolect: Careaors EcAsl
July iI, 199
L%etlon: Robeson County,
NC
lrnestlaalvr: KGK
?flier Geologist
Hand Auger Backl�oe
-- -_-
t
n
t
k `
♦c
<••-• Ilse Distribution
-•-•>
♦
.Interval t♦
t
t
t
" (feat)
t
IN aIA
r
1
loose.
"Ku
r) OA
Sjf&t
a [a1 i'I A i
/ i n
.4- 10
S--20
$via
JJ
�
3.0 -
MoN
•
/
(
`
M01 1
I -so 0
Sr
S
�r
p
!pKO
r�►6 3TK
-
n C
tG1.i
11v D rSf-
i.
M 4�
i 10rv.p
s (.
r
S L
lab
]fr •f6
MO1
—
Y,•-c
�I!��o'
�:. rS
��-
I
f ♦ p�
rcQ
ir{—
a�� GrV
/2 —HIV.
r+w
C-LO
—
t"�nE
f cat
Qt��
Test Note 00.1 3 station:
rr_
D+30 Elevation: IOq# r
r t!
Water Table Elevation: Sfter—
hours. sheet__�,_ol 6
1+30
Te ;1- 4j
C e&V � k
7.5 - 1q.5 I
`7. b ,

I
ercleSt: --
- -- --
Date,
July 12, 199
jocstion: Robeson_CountY.-NC
1!r'ea!<1,f4tecl KGK
Tltte,
Geologist
Hand Auger eci
e
ImpiI n
t
c-•-- Size Distribution
....3,
Interval
' (feet) I/
�t
o -
J
�f�Q
K
dMoatw-
+v.,
- d�
low-
if kk
^
�
C4uS{til
p\•I 'i�Y%�iiL�.\
3 — y
3o-gr
,�•sil�
_
_
l
d-51
sl
y � C
�lo.•Ks
,,, oy({�,
J
_
—yabamr
�4 se—
r tef
8•s- IS
J
I\10•s1
hay d
r
M(r.
Cly
lax- Its
or-aI
frb�
f
t Ina
< <eA,
.f�
r<
at Li
/l on
/I.t- 1
"`°S
sO.7D
...
—
cl�
gf
moist"
h��
,.
�.�! i
e;cdl
N
SC.
hl
tt
►npj'i
r
.\r
`
f
04
..
dthU
ht ed
C
Test Note No.t�w Ststlon� F}��
Elwellons io�•�
water Table Elerstlont
after, hours.
Shset�,of�
I �D 6
t:/ly 4'r"'

trolect:
_ _ p,.1•,i July 12, 199
Location: Robeson County-
NC__
r�ettjaatpr; KGK
?ttlet Geologist
c
Hand Auger/Backhoe
I n
t
c-•-• 81te Distribution
...•a
ti
Interval r
t;
`
(feet)
a
-
7
Iwo�Ras
�r�
��
�y
/oo�
�►►•
Kan
SM
Caai�t�
�A�r horr=.�
p
7
/ — y
IS
n►a
-
—
^�^o.,�
non
yr � Sr7
��
Aq0
�
�
�
i�r�
M�l�
Mts�
�
�
►r
6-3S
y. 1
/S
7 S
o — 7r'j
uto
Mari!-
r
r
�•�si .
fG�
r!!
sA
Test Note No.:.. stetson: > t :Z!Q IIswat Ion:
hater Tsbla�Elevatlons
after_ hours. sheet �of�

�41e�tt_Cc�rta(S __ I-oocQs Tie•.
July 13, 199
LgSstlont Robeson Gou
KGK
Geologist
Hand Auger ack oe
ESM12Mn
<---- Site Olstrlbution ---->
interval
"(reet)
ti
r
G-,t5
Ma ls,
_
h
►..
•C�.iC
Q�9�
rt'e5F
..`
1005�
h a^
s outi(41
,i Ia..;
hit
ru�1
W��'S�
M.
At
A94
f
..
ill
0- (
1
4.,n
y
Mo�e'�
►*`eel
o A
6 . B • /O,
s 3 0
►r, o try
�
�
a
��►!
,�.:,r
�.
k
non
�
A
f)
..
'
feet Role Ra.t 6 Station: B+ZS Elevstlong
hater Table Eteretiom_ *fter,_,,,,
hours. Sheet of
V

a
I=
I

00
It
41
oil
A 1,
�K' j'� ��' h` ,/f .s: - ;t��� !d`.[� CL •,.rl�;�� y'' �/�r. ��i~• F� t �l�"v�µ ,. \_ t �1..�7f� .-•�
��.'� r� !y. � Rem v �,�.•' i %�1'" J ;�,.-f`� ' 'L '�i �10 r, ,
A1E��-
,'- ?+V ♦ �'" _, ti.�'. * .�-`%i,(,.:: ,��s .fir i:.., . , ��,�� �� ,
IN
fig. 4,7
der-
57
Ll
r
_ - r^��f' - ,� � ram• �� . c''�" ,�� t'. tyti.
/
fo
J A f,

■■
■■
on
■■

s
■
u ► !!sue■■��■�....������..
■■■C�� �''�1■ \\\NOON■■/.■■■N71%� ��!!!��
. Vwwm
■OOP
NONE
NONE
■
MEMO

Str_•uctur elevations ARE allowed to change.
i
Fill shrink/swell percent: 1.20 Cut shrink/swell percent: 0.00
Iterating to balancing within 10.0 cubic yards...
delta
Cut
Fill
CUT - FILL
0.00
62796.47
62796.50
-0.03
-0.00
59179.88
69840.29
-10660.41
0.00
59179.85
69840.30
-10660.45
-0.33
62068.16
64168.54
-2100.38
-0.41
62796.40
62796.68
-0.27
Lower "Proposed" by 0.41 feet.
New surface called "Balanced" has been created.
Project: FARM #72
Drawing: SITE WORK
Number: FM72SW
Location: ROBINSON COUNTY, N.C.
Bid Date: N/A
Engineer: N/A
Owner: CARROLL'S FOODS
Estimator: N/A
--------------------------------
Prepared by: using Sitework

Plot of the structure date for the surface:
Balanced
Project: FARM #72
Drawing; SITE WORK
Number: FM72SW
Location: ROBINSON COUNTY# N.C.
Bid Date*. N/A
Engineer*. N/A
Owner'. CARROLL'S FOODS
Estimator: N/A
Prepared bW: using Sitework

id7.61
Plot of the eloping lines for the surface: I
Balanced
Project: FARM ##72
Drawing: SITE WORK
Number: FM72SW
Location: ROBINSON COUNTY, N.C.
Bid Oats: N/A
Engineer: N/A
Owner: CARROLL'S FOODS
Estimator: N/A
Prepared by: using Sitswork

107.99
16s.ge
Plot of the sloping lines for the surface:
Balanced
Project: FARM 072
Drawing: SITE WORK
Number: PM72SW
Location: ROBINSON COUNTY, N.C.
Bid Date: N/A
Engineer: N/A
Owner: CARROLL'S FOODS
Estimator: N/A
Prepared bUt using Sitawork

Plot of the contour date for the surface:
Balanced
Project: FARM 072
Drawing: SITE WORK
Number: PM72SW
Locationt ROBINSON COUNTY* N.C.
Bid pate: N/A
Engineer: N/A
Owner: CARROLL'S FOODS
Estimator: N/A
Prepared bU: using Sitework

4
186.34
103.84
Plot of the sloping lines for the surface:
Balanced
Projects FARM 072
Drawing: SITE WORK
Number: PM728W
Location: ROBINSON COUNTY, N.C.
Bid Dote: N/A
Engineer: N/A
Owner: CARROLL'S FOODS
Estimator: N/A
Prepared bW: using Sitswork

185.59
le4.e9
Plot of th■ sloping line■ for th■ surface%
Balanced
Project: FARM 072
Drawing: SITE WORK
Number: FM72SW
Location: ROBINSON COUNTYp N.C.
Bid Data! N/A
Enginssr: N/A
Owner: CARROLL'S FOODS
Estimator: N/A
Prepared by: using Sitework

18S.84
104. 34
Plot of the sloping lines for the surface:
Balanced
Project: FARM 072
Drawing! SITE WORK
Number: FM72SW
Location: ROBINSON COUNTY, N.C.
Bid Date: NIA
Engineer: N/A
Owner: CARROLL'S FOODS
Entimatar: N/A
Prepared bye: using Sitswork

z_
Lee. Be
104.69
I Plot of the sloping lines for the surface: I
Balanced
Project; FARM #72
Drawing: SITE WORK
Number: FM72SW
Location: ROBINSON COUNTYp N.C.
Bid Dates N/A
Engineer: N/A
Owner: CARROLL'S FOODS
Estimator: N/A
Prepared bU: using Sitawork

166.34
164. B4
Plot of th■ sloping lines for the surface:
Balanced
Project: FARM 072
Drawing: SITE WORK
Numbert FM72SW
Location: ROBINSON COUNTY# N.O.
Bid Data: N/A
Enpinesr: N/A
Owner: CARROLL'S FOODS
Estimator: N/A
Prepared by: using Sitework

1es. 59
105.99
Plot of the ■loping lines for th■ surface:
Balanced
Projects FARM #72
Drawings SITE WORK
Numbers FM7E8W
Location: ROBINSON COUNTY, N.C.
Bid Date: N/A
Engineer: N/A
Owner: CARROLL'S FOODS
Estimator: N/A
Prepared byt using Sitnwork

106.84
LOS.34
Plot of the sloping lines for the surfaces
I I
Balanced
Projects FARM 012
Drawing: SITE WORK
Number: FM72SW
Location: ROBINSON COUNTY# N.C.
Bid Data: N/A
Engineer: N/A
Owner: CARROLL'S FOODS
Estimator: N/A
Prepared bW: using Sitework

187.88
186.69
Plat of the sloping lines for the surface:
Balanced
Project: FARM #72
Drawing: SITE WORT(
Number: FM72SW
Location: ROBINSON COUNTY, N.C.
Hid Data: N/A
Engineer: N/A
Ownert CARROLL'S FOODS
Estimator: NIA
Prepared by! using Sitswork

187.34
iOS.ea
Plot of the sloping lines for the surface:
Balanced
Project: FARM #72
Drawing: SITE WORK
Number: FM72SW
Locstiont ROBINSON COUNTYp N.C.
Bid Dmtet N/A
Engineer: N/A
Owner*. CARROLL'S FOODS
Estimator: N/A
Prepared by: using Sitswork

19
e
�G%.avA•TIIPW4)
ter. S7-1 • 5�kq
\-Tar GI Ktr l en-5kq
�•;w��tz ,v¢F, Ipl.�
00. * Tor
101.48
.69
was
1
gg vs9 ~~ 189. 99 �- = R 1 i9 cogs �{
m p ,
9
.59
2' a 18 1 i6 SL i8 61 34 1
F 4 N i J H i N d
1 4 1 i 1 18 1• 18 1
Plot of all data for the surfacs:
Balanced
Project: FARM 072
Drawing: SITE WORK 4senr}
Number: FM?29W
Location: R99TNSBN COUNTY, N.C.
Bid Date: N/A
Engineer: N/A
Owner: CARROLL'S FOODS
Estimator: N/A
Prepared bW: using Sitework
1
64
eNPA48
.14
49

a
...............................•; - .
'. '-Tol' PI KFi 14Z.
5�e;r. lot, !�tf
191.49
,
gggg
iB iB3.ee
18g.99
i f:
is? fu
7
a
m�
.159
.S9
.69
le)B419
=149
L ; 101.29
�• S .14
lS8sB9` i - - • 195
SIVIIA129
se a 18 4A se 1 .
I N i 7
H t W
1341 18 1e 16 18 S 64
16 m A41a
Plot of all data for the surface:
Balanced
Project: FARM #72
Drawing: SITE WORK
Number: FM72SW
Location: ROBINSON COUNTY, N.C.
Bid Date: N/A
Engineer: N/A
Owner: CARROLL'S FOODS
Estimator: N/A
Prepared bW: using Sitework
5.14
49

0
n
(E VbVh.T IoWS)
zy,
J�. *' Tar
1g1.49
184. a9
I 1
6gg
10 �03.98
LOS.99
if.t
.
1
m
Plot of all date for the surface:
Balanced
Project: FARM #72
Drawing: SITE WORK
Number: PM72SW
Location: ROBINSON COUNTY, N.C.
Bid Data: N/A
Engineert N/A
Owner: CARROLL'S FOODS
Estimator: N/A
Prepared bWt using Sitswork
.59
.69
1 19
A149
1191. 29
6r14
106 6re-Alm
IS4.
64
M J41a
6.14
1w 48

Row Crop Gun Cart with galvanized body is
standard equipment. An optional Low Profile
Gun Cart is also available.
Low Profile Gun Cart (Galvanized Body).
Performance Information :::.•...; :.:
Model
Fww
Ili1.E'r
SPROMM
' WETTED
WETTED
ACRES w/
(G.P.M.)
PRESSURE
PRESSURE
WIDT31
Lei=
t DM -IN
(P.S.L.)
(PAS-L)
(FL)
(FL - YW4
5 DAYS
T40A
280
104
70
240
1370
72
with
300
107
70
250
1375
77
NELSON
SR2Sprinkler
350
116
70
260
1380
. -- . 90
400
126
70
270
•1385 . ; -,102
450
138
70
280
1390 w:
' ; ; _115
480
145
70
290 _
.:1395
. yr 123
T37A
220
99
70
220 `
�1160
wtth
250
104
70
NELSON
300
113
70
" 245
SR150R
: 350
125
70
250 ri
:.
1175":
Sprinkler
>400
137
70
_. .
._ 255 _
r s;
`A1178
.r02::.
420
142
70
' 260 Y°
1.1801:1-.107
z
T30A
180
104
sQ
'2� D
wtm
.`
' �200
111
_.
50
SR150R
129
70
225
.e 1093 z
v
Sprinkler
_.
.y_ 240
137
7D '-,.`r
23Q
�.•
:1095,
a.�
260
147
70
' 235 w
=; 1098
• Recommended width is based on 70% of the wetted diameter
Specifications
Model
T40A
T37A
T30A
Number of Axles
2
1
1
PE Tune LD. On.)
4.0
3.7
3.0
PE Tube Length (fL)
1250
10so
low
Dry weight pbs.)
9100
75W
43M
Weight with water Obs.)
16380
123W
7270
Speed Range (fns./mins.)
10-60
10-60
7-40
Tire size
111.x15
12.5Lx15
11Lx15
Shipping dim.: (1L In.)
Length
1"
15-9
13-S
*Mdth
9.10
9-3
7-5
Height
12.0
11-10
10-0
`Note: T40A/T37A w/o wheels = 8-3 wide
Polyethelene Tube - Only PE tube designed and constructed
for the constant coiling and dragging is considered for use on
Ag-Rain Water -Reels- The tubing is backed by a 5-year
pro -rated warranty.
PE Tube Repair - A simple "screw -in" mender is available for
repairing the PE tube should it become damaged for any
reason.
PE Tube Lengths - Longer tube lengthes are available for all
models. Performance and delivery information available on
request.
AGE �.' : 1 I_N LiiL
600 S. Schrader Ave., P.O. Box 290, Havana, IL 62644
Phone [phone] FAX [phone]
Standard Features
Radial Inflow Turbine - The heart of the drive system.
This extremely efficient motor delivers quiet, smooth,
continuous power. All the water you pump goes through
the sprinkler. None of the water is wasted as in bellows
or piston drives.
Automatic Shutdown for the turbine motor.
Heavy Duty Chassis and frame.
Speedometer.
Pressure Gauge.
Infinitely Adjustable Speed Ranges.
Speed Compensator.
Miswrap Safety Stop.
PTO Rewind and Drive Shaft.
Gun Cart with adjustable wheel width.
Hose Guide to insure proper packing of hose.
Turntable.
Nelson Slow Reverse Gun with ring nozzles.
Lifting Mechanism for gun cart.
Stabilizer Legs - Heaver duty, crank down style.
4" Supply Hose x 30 ft. long with male ring lock
coupler.
Fixed Spool Brake requires no on/off adjustments.
Foolproof Cluth - Turbine and PTO drives cannot be
engaged simultaneously.
Because of mnmrarg proof Impmements, Proms ci machines in the Veaeet may rwt De K*neca) 10 om m pro0uctim. The perfbrmatca mkimmban in tus ft t is based W toss ==W under a paticuW rat or Lam. AMO MW per-
tomtaece may vary from rvs beta oeoerx>:np on va wa =L;msaues of eme. orate, weather, humm 0gemat erd Ow tenors. SpeoScanars aid pries am rttpd m drr V wdW note.
GK 9406VVR-D Prirlad iinU.SA

F'T
fig
;2111. y t '
ir,
fm

WASTE UTZ RATION PLAN
RI;QUiRED SPECiFiCAMNS
L Animal waste small not reach surface waters of the state by runoff drift, manmade conveyances, direct application, or
dire= discharge during operation or land application. Any discharge of waste which reaches surface water is
prohibited
I Tbere must be documematioa in the design folder that the producer either awns or has a notarized agreemc= for use of
SO equate land on which to propedy apply the waste. If the producer does not own adequate land to properly dispose of
waste, helshe shall provide a copy of a notarized agreement with a landowner who is within a reasonable proximny;,
allowing hitalher the use of the land for waste application It is the responsibility of the owner of the facility to s=u=
an update of the Waste Udli=on Plan when there is a change in the operation, increase in the number of aaimais.
method of tears, or available land
3. Amtnal waste shall be applied to mew but not ertcoed, the Nitrogen needs for realistic crop yields based on sort type,
available moisture, historical data, dinoatc conditions, and level of management, unless there art regulations that '
mice the rate of application far other nutrients. Aortal yields may be used in lieu of realistic yield tables at the .
discretion of the planner.
4. Animal waste shall be applied on land eroding less than 5 tons per acre per year. Waste may be applied to land that is
cm4ing at more than 5 tons but less than 10 tons per acre per year providing grass fil= strips are installed where
runo$kaves the field (See FOTG Standard 393-Filter Strips)
S. Odors can be reduced by injecting the waste or disidng after waste appiicatiom Waste should not be applied when there
is danger of drift from the irrigation field
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation hied crops or grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather and Climam in North Carolina» for ,gu d nm )
7. Liquid waste shall be applied at rates not to =oozed the soil mM a:dm ran such than runoff does not or to
surface waters and in a method which does not cause drift from the site during application No ponding should occur
in order to control odor and flies.
$. Animal waste shall not be applied to satxtrated soils, during rainfall ev=M or when the s:ufdec is f tam
9. Animal waste should be applied on actively growing craps in such a matmer that the crop is not covered with waste to
depth that would prohibit growth_ The potcnnal for salt damage from animal waste should also be camsidered
10. Waste shall not be applied in fall or winter for spring plan tod craps on soils with a high potential for leaching -
Waste nutrient loading rates on these soils should be held to a minimum and a suitable winter cover crop phmted to
=aloe up released dents. Waste shah not be applied more than 30 days prior to planting of a crop or Enrages breaking
dormancy-.
11. Any new swine facility sited an or after Ocmbcr 1, 1995 shall comply with the following: The outer perimeter of the
land area onto winch waste is applied from a lagoon that is a component of a swine farm shall be at bast 50 fee from
any residential property boundary and from any perennial stream or rivtr other than an irrigation ditch or canal.
N . NC
JUNE,1996

E)a-I[BlT A 7
r.,�
WASTE UTILIZATION PLAN
REQunu D SPECIFICATIONS
(cenalnsed)
Animal waste other than swine waste from faalities sited on or after October 1, 1995, shall not be applied closer than
25 feet to surface water: This distaamay be reduced for craters that are not perennial provided adequm v v-
$lter strips are present (Sec Standard 393 -Filter Strips).
12_ Animal waste shall not be applied closer than 100 feet from wens.
13. Animal waste shall not be applied closer than 200 fit of dwellings other than those owned by landowner.
14. Waste shall be applied in a manner not to reach other property and public right-of-ways.
15. Animals waste shall not be discharged into surface waters; drainagrways or wedan& by a discharge or by over -
spraying: Animal waste maybe applied to prior converted cropland provided it has berg approved as a land
applications site by a "mchuical specialist". Animal waste applied on grassed waterways shall be at agronomic rases
and in a manner that anuses no runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities; showers, toilets, sinks, etc., shall not be discharged into the
aalmal waste management system.
17. A pi otecthm cover of appropriate won will be established on all disnsrbed areas (lagoon embankments, berms,
pipe rims, ems). Areas shall be fenced, as necessary, to protect the vegetation. Vegcsation such as trees, daubs, and
other woody species, etc. are limited to areas where considered appropriate lagoon areas should be ]wept mowed and
accessible. -Lagoon berms and stramtras shuul3 be impeded regularly for evidence of erasion, leakage, or discharge.
19. Jf animal won at the ba-1hp is termiaared, the owner is responsr)ie for obtaining and implementing a "closure
place" which will elf —in atr the possibility of an illegal discharge, pollution and erosion.
19. Waste handling st mca= piping, pumps, reels, etc., should be inspected on a regular basis to preveai breakdowns,
leaks, and spells. A regular Maintenance checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other sops for direct human consumption.
However, if animal waste is used on amps for direct human consumption it should only be applied preplot-with no
further applications of animal waste during the crop season.
21. Highly visible permanent markers shall be installed to mark the top and bottom elevations of the temporary storage
(pumping valUMe) of all waste treatment lagoons_ Pumping shall be managed to maintain the liquid level betty= the
Markers. A maeker will be req red to mark the wxdrman storage volume for waste storage ponds.
22. Soil tests shall be made every two years and a liquid waste analysis be taken at least twice each year consistent with
waste uulinticn plan. Poultry Iitt= shall be tested prior to application. Sort and waste analysis records sball be kept
for five years.
23. Dead animals will be disposed of in a manner that mr.-ts NC regulations.
NR=, NC
AJNR, 1996

- North Carolina Agricultural Extension Service
Agri -Waste Management
Biological and Agricultural Fxpneehng North Carolina State University
LIVESTOCK WASTE SAMPLING, ANALYSIS AND CALCULATION
OF LAND APPLICATION RATES
James C. Barker*
L SAMPLE COLLECTION
A Semi -Solid Lot Manure
L Scraped directly from lot into spun.der
a) From loaded spreader, collect about 2 lbs of manure from different locations using
nonmetallic collectors.
It ii. From Storage
a) Collect about 2 lbs of manure from an the surface crust avoiding bedding materials and
using nonmetallic collectors
-- . B. Liquid Manure Slurry
i. Under -slotted -floor pit
a) Extend a %" nonmetallic conduit open on both ends into mamm to pit floor.
b) Seal upper end of conduit (e.g., by placing a thumb over end of conduit) trapping mamn
that has entered lower end, remove and empty slurry into plastic buckd or nonmetallic
container.
c) Take subsamples from S or more Locations or at least 1 quart.
d) Mix and add about'/, pint to nonmetallic sample container.
ii. Exterior storage basin or tank
a) Make sure manure has been well mixed with a liquid manure chopper -agitator
pump or propeller aatitor_
b) Take subsamples from about 5 pit locations, from agitator pump or from manna spreader
and place in a plastic bucket.
* Professor and Extension Specialist, Biological and Agricultural Engineering
Department, North Carolina State University, Raleigh, NC

IL SAMPLE PREPARATION AND TRANSFER
A Place sample into an expandable container that can be scaled. Rinse residues from container with
clean water but do not use disinfectants, soaps, or treat in any other way-
B. Pack sample in ice, refrigerate, fi=e, or transfer to lab quickly.
C. Hand -delivery is most reliable way of sample trans6
D. If mailed, protect sample container with packing material such as newspaper, box or package with
gypping Paper, and tape.
E. Commercial sample containers and mailers are also available, Contacts:
1. A& L Eastern Agricultural Lab, Inc.
7621 Whitepbae Road
Richmond, VA 23237
Ph. [phone]
2. Fisher Scientific Co.
3315 Winton Road
Raleigh, NC 27604
It Ph: [phone]
3, Polyfoam Packets Corp.
2320 S. Foster Avenue
Wheeling, IL 60090
Ph: (312) 39"110
4. NASCO
901 Janesville Avenue
Fort Atkinson, WI 53538
Ph: [phone]
F. Private analytical labs are available, but sample analyses are costly.
G- The NCDA provides this service for North Carolina residents.
i. Address: North Carolina Department of Agriculture
ii. Agronomic Division
Plant/Waste/Solution Advisory Section
Blue Ridge Road Center
P. O. Box 27647
Raleigh, NC 27611
Ph: [phone]
Attu Dr. Ray Campbell
iii. Forward $4 along with the sample
iv. Include the following identification informia= with sample.
a) Livestock species (dairy, swine, turkey, etc.)
b) Livestock usage (swine -nursery, finishing, turkey -breeders, brooderhouse, grower, number
flocks grown on litter, etc.)
c) Waste type (dairy lot scraped ma=e, liquid Amy, swine-pt slurry lagoon liquid, sludge;
broiler -house litter, stockpile)
v. Routine analyses performed on all samples: N, P, V., Ca, Mg, Ma, S, Fe, Ma, Zn, Cu, B
vi. Additional analyses performed upon request: DM, lino, Cd, N4 Pb

EMERGENCY ACTION PLAN
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing, or running off site. You should not wait until wastes reach surface waters or
Ieave your property to consider that you have a problem. You should make every effort to
ensure that this does not happen. This plan should be posted in an accessible location for
all employees at the facility. The following are some action items you should take_
1. Stop the release of wastes. Depending on the situation, this may or may not be
possible. Suggested responses to some possible problems are listed below.
A. Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B: Runoff from waste application field -actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and ehminate the reason(s) that caused the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C: Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
C. Close valves to eliminate further discharge:
d. Repair all leaks prior to restarting pumps.
D: Leakage from flush systems, houses, solid separators -action include:
a. Stop recycle pump.
b_ Stop irrigation pump.
c. 1**Sake sure no siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
December 18, 1996

e. Repair all leaks prior to restarting pumps.
E, Leakage from base or sidewall of lagoon. Often this is seepage as opposed to
flowing leaks- possible action:
a. Dig a small sump or ditch away from the embanent to catch all seepage,
put in a submersible pump, and pump back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon
bottom as soon as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. ApproximateIy how much was released and for what duration?
c. Any damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off of the property)?
h. How much reached surface waters?
3: Contact appropriate agencies.
a. During normal business hours, call your DWQ (Division of Water Quality)
regional office; Phone - . . After hours, emergency number. 919-733-3942.
Your phone call should include: your name, facility, telephone number, the details
of the incident from item 2 above, the exact location of the facility, the location or
direction of movement of the spill, weather and wind conditions. The corrective
measures that have been under taken, and the seriousness of the situation.
b. If spill leaves property or enters surface waters, call Iocal EMS Phone number -
c. Instruct EMS to contact local Health Department
d. Contact CES, phone number - - , local SWCD office phone number
and local MRCS office for advice/technical assistance phone number - -
4: If none of the above works call 911 or the Sheriffs Department and explain your
problem to them and ask that person to contact the proper agencies for you.
5: Contact the contractor of your choice to begin repair of problem to minimize off -site
damage..
a. Contractors Name: 4 - - L 1 S -015
b. Contractors Address: 3 c 5
c. Contractors Phone: 9 10 -
2 December 18, 1996

D
6: Contact the technical specialist who certified the lagoon (MRCS, Consulting
Engineer, etc.)
a. Name: 9 0"JIA Rd n �C. um
b. Phone: R 1 4- 1 3 -43 !t -
7: Implement procedures as advised by DWQ and technical assistance agencies to
rectify the damage, repair the system, and reassess the waste management plan to
keep problems with release of wastes from happening again.
3 December 18, 1996

Source
Cause
BMPs to Minimize Oddr Site Specific Practices
End of drainpipes at
•
Agitation during wastewater
C1 Extend discharge point of pipes underneath
lagoon
conveyance
lagoon liquid level
Lagoon surfaces
•
Volatile gas emissions;
Proper lagoon liquid c4pacity;
•
Biological mixing;
A3__Correcl lagoon startup procedures;
a
Agitatio
inimum surface area -to -volume ratio;
;_�Mlinimum
agitation when.pumping;
Mechanical aeration;
Cl Proven biological additives
Irrigation sprinkler
•
High pressure agitation;
Irrigate on dry days with little or no wind;
nozzles
•
Wind drift
�1' Minimum recommended operating pressure;
Pump Intake near lagoon liquid surface;
C] Pump from second -stage lagoon
Storage tank or basin
•
Partial microbial decomposition;
C] Bottom or midlevel loading;
surface
.
Mixing while filling;
O Tank covers;
•
Agitation when emptying
17 Basin surface mats of solids;
CI Proven biological additives or oxidants
Settling basin surface
•
Partial microbial decomposition;
❑ Extend drainpipe outlets underneath liquid
•
Mixing while filling;
level;
•
Agitation when emptying.
O Remove settled solids regularly
Manure, slurry or sludge
•
Agitation when spreading;
C1 Soil injection of slurry/sludges;
spreader outlets
.
Volatile gas emissions
C3 Wash residual manure from spreader after use;
CI Proven biological additives or oxidants
Uncovered manure,
•
Volatile gas emissions while
13 Soil injection of slurry/sludges
slurry or sludge on field
drying
❑ Soil incorporation within 49 hrs.;
surfaces
a ..
CV. Spread In thin uniform layers for rapid drying;
17 Proven biological additives or oxidants
Dead animals • Carcass decomposition Aff Proper disposition of carcasses
Dead animal disposal + Carcass decomposition 13 Complete covering of carcasses in burial pits;
pHs ' : CI Proper location/construction of disposal pits
Incinerators • incomplete combustion Cl Secondary stack burners
A► " 'C -November 11, 1996, Page 4

i,
Insect Control Checklist for Animal Operations
Source Cause BMPs to Control Insects Site Specltic Practices
Flush Gutters • Accumulation of solids )3"' Flush system is designed and operated
sufficiently to remove accumulated solids firom
gutters as designed.
Remove bridging of accumulated solids at
discharge
Lagoons and Pits • Crusted Solids aintain lagoons, settling basins and pits where --
pest breeding is apparent to minimize the
crusting of solids to a depth of na more than G -
B inches over more than 30% of surface.
Excessive Vegetative • Decaying vegetation Maintain vegetative control along banks of
Growth lagoons and other impoundments to prevent
accumulation of decaying vegetative matter
along watees edge on impoundment's perimeter.
Dry Systems
Feeders a Feed Spillage pesign, operate and maintain feed systems (e.g.,
bunkers and troughs) to minimize the
accumulation of decaying wastage.
AT�Clean up spillage on a routine basis (e.g., 7 - 10
day interval during summer; 15-30 day interval
_during winter).
Feed Storage• Accumulations of feed residues Reduce moisture accumulation within and
around immediate perimeter of feed storage
areas by insuring drainage away from site
and/or providing adequate containment (e.g.,
covered bin for brewer's grain and similar high
moisture grain products).
4 inspect for and remove or break up accumulated
solids in filter strips around feed storage as
needed.,ti,.. • ., , ,
AM" -November 11, 1996, Page l

1
s
r Mortality Management Methods
1. (check which method(s) are being implemented)
❑ Burial three feet beneath the surface of the ground within 24 hours after
knowledge of the death. The burial must be at least 300 feet from any flowing
stream or public body of water.
Ekl--, Rendering at a rendering plant licensed under G.S. 106-168.7
❑ Complete incineration
❑ In the case of dead poultry only, placing in a disposal pit of a size and design
approved by the Department of Agriculture
❑ Any method which in the professional opinion of the State Veterinarian would
make possible the salvage of part of a dead animal's value without endangering
human or animal health. (Written approval of the State Veterinarian must be
attached) _
f -
December 18, I996