470031_CORRESPONDENCE_20171231

Revised January 22, 1999
JUSTIFICATION & DOCUMENTATION FOR MANDATORY WA DETERMINATION
Facility Number Operation is flagged for a wettable
Farm Name: acre determination due to failure of
On -Site Representative: r Part ll eligibility item(s) Ft F2 F3 F4
Inspector/Reviewer's Name: Operation not required to secure WA
determination at this time based on
Date of site visit: ��-�9 exemption E1 E2 E3 E4
Date of most recent WUP:_ ?-2? -f Annual farm PAN deficit: YS/z pounds
Irrigation Systems) - circle #: 1. hard -hose traveler; 2. center -pivot system; 3. linear -move system;
4. stationary sprinkler system wlpermanent pipe; 5. stationary sprinklers stem wlportable pipe;
6. stationary gun system wlpermanent pipe; stationary gun sys em wlporta a pip
PART I. WA Determination Exemptions (Eligibility failure, Part 11, overrides Part I exemption.)
E1 Adequate irrigation design, including map depicting wettable acres, is complete
and signed by an I or PE.
E2 Adequate D, and D)D3 irrigation operating parameter sheets, including map
depicting wettable acres, is complete and signed by an I or PE.
E3 Adequate D, irrigation operating parameter sheet, including map depicting
wettable acres, is complete and signed by a WUP.
E4 75% rule exemption as verified in Part III. (NOTE: 75 % exemption cannot be
applied to farms that fall the eligibility checklist in Part II. Complete eligibility
checklist, Part II - F1 F2 F3, before completing computational table in Part III).
PART II. 75% Rule Eligibility Checklist and Documentation of WA Determination
Requirements. WA Determination required because operation fails one of the eligibility
requirements listed below:
F1 Lack of acreage which resulted in over application of wastewater (PAN) on spray
field(s) according to farm's last two years of irrigation records.
1/F2 Unclear, illegible, or lack of information/map.
F3 Obvious field limitations (numerous ditches; failure to deduct required
buffer/setback acreage; or 25% of total acreage identified in CAWMP includes
small, irregularly shaped fields - fields less than 5 acres for travelers or less than
2 acres for stationary sprinklers).
F4 WA determination required because CAWMP credits field(s)'s acreage in excess
of 75% of the respective field's total acreage as noted in table in Part 111.
Facility Number f 7 - 31

Revised January 22, 1999
Part Ill. Field by Field Determination of 75% Exemption Rule for WA Determination
TRACT
NUMBER
FIELD
'NUMBER'-'
TYPE OF
IRRIGATION
SYSTEM
TOTAL
ACRES
CAWMP
ACRES
FIELD
COMMENTS'
U
S
7
FIELD NUMBER - hydrant, pull, zone, or point numbers may be used in place of field numbers depending on CAWMP
and type of irrigation system. If pulls, etc. cross more than one field, inspector/reviewer will have to combine fields to
calculate 75% field by field determination for exemption if possible; otherwise operation will be subject to WA
determination.
FIELD NUMBER' - must be clearly delineated on map.
COMMENTS' - back-up fields with CAWMP acreage exceeding 75% of its total acres and having received less than 50%
of its annual PAN as documented in the farm's previous two years' (1997 & 1998) of irrigation records, cannot serve as the
sole basis for requiring a WA Determination. Sack -up fields must be noted in the comment section and must be accessible
by irrigation system.

North Carolina
Department of Environment and Natural Resources
Water Pollution Control System Operator Certification Commission
Michael F. Easley, Governor
William G. Ross Jr., Secretary
Coleen H. Sullins, Chairman
February 21, 2001
Roy & Richard Wood
4051 Aberdeen Road
Raeford NC 28376
SUBJECT: Designation of Operator in Charge
Farm Name: R&R Pork Farm
Facility ID #: 47-31
County: Hoke
Dear Mr. Wood:
e�A
NCDEN.R
GEAR 2 7 2001
Senate Bill 1217, An Act to Implement Recommendations of the Blue Ribbon Study Commission on Agricultural
Waste, was enacted by the 1996 North Carolina General Assembly. This legislation requires owner of a certified
operator for each animal waste management system that serves 250 or more swine, 100 or more confined cattle,
75 or more horses, 1,000 or more sheep, or 30,000 or more confined poultry with a liquid waste management
system.
Our records indicate that the operator designated as the Operator In Charge (OTC) for your animal waste
management system is no longer certified. Therefore, you must designate a properly certified animal waste
management system operator as the OIC for your facility. The enclosed designation form must be returned to this
office by April 1, 2001. This office maintains a list of certified operators in your area if you need assistance in
locating a certified operator.
Failure to designate a properly certified Operator in Charge for your facility is a violation of N.C.G.S. 90A-47.2
and 15A NCAC 8F .0201(a) and may result in the initiation of enforcement action. Please be advised that nothing
in this letter should be taken as resolving you of the responsibility and liability for any past or future violations for
your failure to have a properly certified Operator in Charge designated for your animal waste management system.
If you have questions concerning this matter, or if this office can be of further assistance, please call Beth
Buffington at [phone], extension 313.
Sincerely,
L7A,,,-;jp Xr,�
Dwight Lancaster, Supervisor
Technical Assistance and Certification Unit
Enclosure
cc: TAC Files
Non -Discharge Compliance/Enforcement Unit
Fayetteville Regional Office
Central Files
1618 Mail Service Center, Raleigh, North Carolina 27699-1618
Phone: 919 — 733-0026 1 FAX: 919 — 733-1338
AN EQUAL OPPORTUNITY 1 AFFIRMATIVE ACTION EMPLOYER - 50% RECYCLED 1 10% POST CONSUMER PAPER

State of North Carolina
Department of Environment
and Natural Resources
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
CERTIFIED MAIL
RETURN RECEIPT REOUESTED
Roy & Richard Wood
R&R Pork Farm
4051 Aberdeen Road
Raeford NC 28376
Dear Roy & Richard Wood:
NCDENR
(NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT ANo NATURAL RESOURcEs
October 2, 2000�
OCT 13 2000
FAY ETTEVILLE
r:_E( . C - - '`nr---
Subject: Notification for Wettable Acre Determination
Animal Waste Management System
R&R Pork Faun
Facility Number 47-31
Hoke County
A letter dated January 15, 1999 was sent to advise you about concerns associated with Certified Animal
Waste Management Plans and the method by which the irrigated acres within the plans were calculated. Only
the acres that are wetted can be credited in the waste management plan as receiving waste application. Any
acreage within the plan that can not be reached by waste application equipment can not be used as part of your
plan.
An evaluation by Bob Heath on 313/99 was made to review the actual number of acres at your facility that
receive animal waste during land application. The evaluation of your facility has yielded one of the following
two results as indicated by the box marked with an "X".
Category 1:
❑ The evaluation of your facility could not be completed due to a lack of information. Please
contact your Technical Specialist to assist in providing Bob Heath the necessary
information to potentially exempt your facility from undergoing a complete wettable acre
determination. Please submit this information to Bob Heath, at 225 Green Street, Suite
714, Fayetteville, NC 28301, within in 90 days of the receipt of this letter. If you have any
questions please contact Bob Heath at [phone]. If within 90 days you are unable
to provide Bob Heath with the information you are automatically required to complete
a Wettable Acre Determination as described by Category 2 below, within 180 days
of receipt of this letter.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycledl10% post -consumer paper

Notification for Wettable Acre Determination
Animal Waste Management System
Page 2
Category 2:
(� Your facility has been identified by the Department of Environment and Natural Resources
as a facility that may have overestimated the number of acres actually receiving animal
waste. Therefore, some or all of your fields may be exceeding the allowable loading rates
set in your Certified Animal Waste Management Plan.
In order to resolve this issue, please contact a designated Technical Specialist to have him
or her conduct a Wettable Acre Determination for your facility. The Technical Specialist must
be one that has been approved by the Soil and Water Conservation Commission to conduct
Wettable Acre Determinations. Many Technical Specialist with the N.C. Cooperative Extension
Service, the Soil and Water Conservation Districts, the Natural Resources Conservation
Service, and the Division of Soil and Water Conservation have received this, special
designation. You may also contact a private Technical Specialist who has received this
designation, or a Professional Engineer.
All needed modifications to your Animal Waste Management System must be made and
the Wettable Acres Determination Certification must be returned to DWQ within the neat
180 days. if the needed modifications are not made and if the form is not returned within the
required time, DWQ will be forced to take appropriate enforcement actions to bring this facility
into compliance. These actions may include civil penalty assessments, permit revocation,
and/or injunctive relief.
Once a Wettable Acre Determination has been completed, a copy of the attached Wettable
Acre Determination Certification must be submitted to the address listed on the form. Please
note that both the owner and the Technical Specialist must sign the certification. A copy of all
the Wettable Acre Determination documentation that applies to your Waste Utilization Plan
must be kept at your facility. DWQ and the Division of Soil & Water Conservation Staff will
review all documentation during their annual visit of your facility. An additional copy must by
kept on file at the local Soil & Water Conservation District Office. Please note that if you install
or modify your irrigation system, a designated Irrigation Specialist or a Professional Engineer
must also sign the Wettable Acre Determination Certification.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Sonya Avant of our
Central Office staff at [phone] ext. 571.
Sincerely,
Kerr T. Stevens
cc: Fayetteville Regional Office
Hoke County Soil and Water Conservation District
Facility File

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
January 26, 1999
Roy & Richard Wood
R&R Pork Farm
4051 Aberdeen Rd
Raeford NC 28376
ffl?*WA
IT 0
- - f
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Certificate of Coverage No. AWS470031
R&R Pork Farm
Swine Waste Collection, Treatment,
Storage and Application System
Hoke County
Dear Richard C. Wood:
r•
In accordance with your application received on October 22, 1998, we are forwarding this Certificate of
Coverage (COC) issued to Roy & Richard Wood, authorizing the operation of the subject animal waste
collection, treatment, storage and land application system in accordance with General Permit
AWG100000.,,This approval shall consist of the operation of this system including, but not limited to,
the management of animal waste from the R&R Pork Farm, located in Hoke County, with an animal
capacity of no greater than 1,70 Farrow to Wean and the application to land as specified in the Certified
Animal Waste Management'Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This request
shall be made within 30 days of notification by the Division.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the DWQ prior to a name change or change in ownership.
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Certificate of Coverage AWS470031
R&R Pork Farm
Page 2
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual non -discharge permit by contacting the engineer listed below for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
The subject farm is located in the Fayetteville Regional Office. The Regional Office Water Quality Staff
may be reached at [phone]. If you need additional information concerning this COC or the
General Permit, please contact Sue Homewood at [phone] ext. 502.
Sincere
-A. Preston Howard, Jr., F.E.
RECEIVELi
cc: (Certificate of Coverage only for all cc's)
Hoke County Health Department FEB j 1999
F-ayeftville°Regio—naFGff c6, Wate—r-Q ality-Sectiorwi
Hoke County Soil and Water Conservation District FAYETTEVILLE
Permit File REG.y E
NDPU Files

State of North Carolina E
Department of Environment and Natural Resou>r ra al:-C , ,U�iION
Division of Water Quality
Non -Discharge Permit Application Form �Orj 2 ? 1098
(THIS FORM MAY BE PHOTOCOPIED FOR USE AS AN ORIGINAL)
General Permit - Existing Liquid Animal Waste Opeption��Imit�3�
The following questions have been completed utilizing information on file with the Division. Please
review the information for completeness and make any corrections which are appropriate. If a
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
1. GENERAL INFORMATION: ,
1.1 Facility Name: .fie rr � 9
1.2 Print. Land Owner's name: Roy & Richard Wood
1.3 Mailing address: 4051 Aberdeen Rd
City, State: Raeford NC Zip: 28376
Telephone Number (include area code): 910-875-2794
1.4 County where facility is located: Hoke
1.5 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a
copy of a county road map with the location of the farm identified): NC 211 at Calloway Rd (SR 1214) intersection
1.6 Print Farm Manager's name (if different from Land Owner):
1.7 Lessee's / Integrator's name (if applicable; please circle which,type ip listed):
1.8 Date Facility Originally Began Operation:
1.9 Date(s) of Facility Expansion(s) (if applicable):
2. OPERATION INFORMATION:
2.1 Facility No.: 47 (county number); 3 l (facility number).
2.2 Operation Descri�pt Swine operation
grow to Wean
770- Certified Design Capacity
Is the above information correct? dyes; no. If no, correct below using the design capacity of the facility
The "No. of Animals" should be the mAffium num er or which the waste management structures were designed.
Type of Swine
0 Wean to Feeder
0 Feeder to Finish
0 Farrow to Wean (# sow)
0 Farrow to Feeder (# sow)
0 Farrow to Finish (# sow)
No. of Animals Tie of Pouf No. of Animals
Other Type of Livestock on the farm:
0 Layer
0 Non -Layer
0 Turkey
Type of Cattle No. of Animals
0 Dairy
0 Beef
No. of Animals:
RECEA��'��
r --i ! =ii•q
FORM: AWO-G-E 5/28/98 Page 1 of 4 47 - 31 i"t"FTTr�; 4 y

2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): _ 20 ; Required Acreage (as listed in the AWMP): 15
2.4 NumberCfIagoo storage ponds (circle which is applicable):
2.5 Are subsdrains present within 100' of any of the application fields? YES o NO lease circle one}
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES or O please circle one)
2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, NRCS Standards, etc.) (Swine Only)
YES or NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited?
What was the date that this facility's land application areas were sited? AF 2 -
3. REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
it
Applicants Initials
3.1 One completed and signed original and one copy of the application for General Permit -Animal
Waste Operations;
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit
application for animal waste operations.
,The CAWMP must include the following components:
3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application.
3.3.4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application field.
3.3.8 The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.10 A site schematic.
3.11 Emergency Action Plan.
�.3.12 Insect Control Checklist with chasm best management practices noted.
3.13 Odor Control Checklist with chosen best management practices noted.
.14 Mortality Control Checklist with the selected method noted.
.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility.
3.16 Operation and Maintenance Plan.
If your CAWMP includes any components not shown on this list, please include the
additional components with your submittal.
FORM: AWO-G-E 5/28/98 Page 2 of 4 47 - 31

Facility Number: 47 - 31
Facility Name: R.W. Farms
4. APPLIC NT'S CERTIFICATIOF:
JI, r , ,p (Land Owner's name listed in question 1.2), attest that
this application for r D I'/-- A'.' (Facility name Iisted in question 1.1)
has been reviewed by m6 and is accurate and complete tote best of my knowledge. I understand that if all required parts of this
application are not co a ha quired supporting information and attachments are not included, this application
package will be rn�d t a om e.
Signature Date
5. MANAGER'S CERTIFICATION: (complete only if different from the Land Owner)
I, (Manager's name listed in question 1.6), attest that this
application for (Facility name listed in question I.1)
has been reviewed by me and is accuratecomplete 6-Uie best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned as incomplete.
Signature - Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
FORM: AWO-G-E 5/28/98 Page 3 of 4 47 - 3l

Z c
Swine Farm Waste Management Odor Control Checklist
Sotkrce ' Cause BMPs to Minimize Odor Site Specific Practices
Farmsiiad i--. N e Swine production O Vegetative or wooded buffers
G' a recommended best management practices
Good judgment and common sense
Animal body • Dirty manure -covered D Dry floors
surfaces animals
Floor surfaces o Wet manure -covered floors ©'Slotted floors
M Waterers located over slotted floors
O F ders at high end of solid floors
pe manure buildup from floors
:._Underfloor ventilation for drying
Manure collection Y Urine Or Frequent manure removal by flush, pit recharge,
pits . Partial microbial crape
decomposition Underfloor ventilation
Ventilation exhaust • Volatile gases RoTgwmaintenance
fans
• Dust
ent air movement
Indoor surfaces a Dust S" Washdown between groups of animals
Feed additives
O Feeder covers
C7 Feed delivery downspout extenders to feeder
covers
Flush tanks o Agitation of recycled lagoon 0 Flush tank covers
` liquid while tanks are filling 0 Extend fill lines to near bottom of tanks with '
anti -siphon vents

1
3
Swine Farm Waste Management Odor Control Checklist
Source Cause BMPs to Minimize Odor Site Specific Practices
Flush alleys • Agitation during wastewater O Underfloor flush with underfloor ventilation
conveyance
r%lam
Pit recharge points • Agitation of recycled lagoon 0 Extend recharge lines to near bottom of pits with
liquid while pits are filling anti -siphon vents.
Lift stations • Agitation during sump tank O Sump tank covers
filling and drawdown
Outside drain • Agitation during wastewater O Box covers
collection or conveyancd
junction boxes
End of drainpipes • Agitation during wastewater O Exterid discharge point of pipes underneath
at lagoon conveyance Icon liquid level
Lagoon surfaces • Volatile gas emissions
• Biological mixing
+ Agitation
G"Pro r lagoon liquid capacity
C'YClmum
ct lagoon startup procedures
0 surface area -to -volume ratio
Minimum agitation when pumping
O Mechanical aeration
C] P5oVen biological additives
Irrigation sprinkler • High pressure agitation �01"Irrigate on dry days with little or no wind
nozzles + Wind drift Vnium mrecommended operating pressure
mp intake near lagoon liquid surface
- 0 Pump from second -stage lagoon

r'
Swine Farm Waste Management Odor Control Checklist
Source Cause BMPs to Minimize Odor Site Specific Practi s
Manure tracked onto • Poorly maintained access 0 Farm access road maintenance
public roads from roads
farm access
Additional Information: Available From:
Swine Manure Management; .0200 Rule/BMP Packet NCSU, County Extension Center
Swine Production Farm Potential Odor Sources and Remedies; EBAE Fact Sheet NCSU=BAE
Swine Production Facility Manure Management: Pit Recharge —Lagoon Treatment; EBAE 128-88 NCSU—BAE
Swine Production Facility Manure Management: Underfloor Flusli--Lagoon Treatment; EBAE 129-88 NCSU—BAE
Lagoon Design and Management for Livestock Manure Treatment and Storage; EBAE 103-83 NCSU—BAE
Calibration of Manure and Wastewater Application Equipment; EBAE Fact Sheet NCSU—BAE
Controlling Odors from Swine Buildings; PIH-33 NCSU—Swine Extension
Environmental Assurance Program; NPPC Manual N.C. Pork Producers Assoc.
Options for Managing Odor, a report from the Swine Odor Task Force NCSU Agricultural Communications
Nuisance Concerns in Animal Manure Management: Odors and Flies; PRO107, 1995 Conference Proceedings Florida Cooperative Extension

Insect Control Checklist for Animal Operations
Source Cause BMPs to Control Insects Site Specific Practices
Liquid Systems
Flush gutters • Accumulation of solids
O Flush system is designed and operated
sufficiently to remove accumulated solids from
gutters as designed
O Remove bridging of accumulated solids at
' charge
Lagoons and pits • Crusted solids
gr Maintain lagoons, settling basins and pits where
pest breeding is apparent to minimize the crusting
f
of soli to a depth of no more than 6 to 8 inches �
?"Ydmore than 30 percent of surface
Excessive vegetative • Decaying vegetation
Maintain vegetative control along banks of
growth
lagoons and other impoundments to prevent :
accumulation of decaying vegetative matter along
water's edge on impoundment's perimeter.
Dry Systems
Feeders • Feed spillage
De ' n, operate, and maintain feed systems
.g., bunkers and troughs) to minimize the
ccumulation of decaying wastage
Clean up spillage on a routine basis (e.g., 7- to 10-
_
day interval during summer; 15- to 30-day interval
during winter)

Mortality Management Methods
(check which method(s) are being implemented)
❑ Burial three feet beneath the surface of the ground within 24 hours after
,knowledge of the death. The burial must be at least 300 feet from any flowing
ar/stream or public body of water.
Rendering at a rendering plant licensed tender G.S. 106-168.7
. ❑ Complete'incineration
❑ In the case of dead poultry only, placing in a disposal pit of a size and design
approved by the Department of Agriculture
❑ Any method which in the professional opinion of the State Veterinarian would
make possible the salvage of part of a dead animal's value without endangering
human or animal health. (Written approval of the State Veterinarian must be
attached)
December 18, 1996

ANIMAL WASTE UTILIZATION PLAN
Producer:
Location:
Telephone:
Type Operation:
Number of Animals:
(Design Capacity)
STORAGE STRUCTURE:
Richard Wood
RECEIVED_
WA R Q' +p.3iY SE01 ION
[OPT 1998
4051 Aberdeen Rd.
Raeford NC 28376 Non-Disczhargo permitting
910-875-7985
Existing Farrow to Weanling Swine
770.00 sows
RECEIVE1D
Anaerobic Waste Treatment Lagoon NEB 1 1999
APPLICATION METHOD: Irrigation FAYMEVILLE
REG. : 'E
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops
in the fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply
more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall be applied to land eroding at less than
5 tons per acre per year. Waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on saturated soils, when it is raining,
or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed
under DWQ regulations.
Page: 1

ANIMAL WASTE UTILIZATION PLAN
5. Wind conditions should also be considered to avoid drift and
downwind odor problems.
6. To maximize the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied'to a growing crop or applied not more than 30
days prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. If
you choose to change methods in the future, you need to revise this
plan. Nutrient levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from your
waste management facility. In some cases you may want to have plant
analysis made, which could allow additional waste to be applied.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
This waste utilization plan, if carried out, meets the requirements
for compliance with 15A NCAC 2H .0217 adopted by the Environmental
Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
770 sows x 6.1 tons waste/sows/year = 4697 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
770 sows x 5.4 lbs PAN/sows/year = 4158 lbs. PAN/year
Applying the above amount of waste is a big job. You should plan time
and have appropriate equipment to apply the waste in a timely manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
Page: 2

ANIMAL WASTE UTILIZATION PLAN
TABLE 1: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
------
APPLY
RESID.
APPLIC
METH
N
TIME
840
3
CaB
BH
5.0
250
0
6.3
1575
I
APR-SEP
840
-3 1
840
1
CaB
840
1-1
840
15A
CaB
840
-5A
856
1A
CaB
856
"1A
END
G
0
I
11
�50
16.3
1315
SEP-NOV
BH
5.0
D
I
I
1250
110
�2500
APR-SEP
SG
1
0
I
150
110
1500
SEP-NOV
BH
5.0
0
6
I
I
1250
11500
APR-SEP
SG
1
0
6
I
150
1300
SEP-NOV
BH
5.0
0
I
1250
16.6
11650
APR-SEP
SG
1
0
I
�50
�6.6
�330
SEP-NOV
I
TOTAL18670
- Indicates that this field is being overseeded (i.e. interplanted)
or winter annuals follow summer annuals.
NOTE: The applicator is cautioned that P and K may be over applied
while meeting the N requirements. In the future, regulations may
require farmers in some parts of North Carolina to have a
nutrient management plan that addresses all nutrients. This plan
only addresses nitrogen.
Page: 3

VA
ANIMAL WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
See required specification 2.)
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
__-_---
APPLY
RESID.
APPLIC
METH
N
TIME
END
TOTAL 10
Indicates that this field is being overseeded (i.e. interplanted) or
winter annuals follow summer annuals.
In interplanted fields (i.e. small grain, etc, interseeded
in bermudagrass), forage must be removed through grazing,
hay and/or silage. Where grazing, plants should be grazed
when they reach a height of six to nine inches. Cattle
should be removed when plants are grazed to a height of four
inches. In fields where small grain, etc, is to be removed
for hay or silage, care should be exercised not to let small
grain to reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too
high and this will definitely interfere with stand of
bermudagrass. This loss of stand will result in reduced
yields and less nitrogen being utilized. Rather than
cutting small grain for hay or silage just before heading as
is the normal situation, you are encouraged to cut the small
grain earlier. You may want to consider harvesting hay or
silage two to three times during the season, depending on
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late
September or early October. Drilling is recommended over
broadcasting. Bermudagrass should be grazed or mowed to a
height of about two inches before drilling for best results.
Page: 4

ANIMAL WASTE UTILIZATION PLAN
** Acreage figures may exceed total acreage in fields due to
overseeding.
* lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and 2 above:
CROP CODE
CROP
UNITS
PER UNIT
BH
SG
HYBRID BERMUDAGRASS-HAY
SMALL GRAIN OVERSEEDED
TONS
AC
50
50
TABLE 1
TABLE 2
TOTAL
TOTALS FROM TABLES 1 AND 2
ACRES
LBS AW N USED
28.9
8670
0
0
28.9
8670
* BALANCE
-4512
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.
Page: 5

ANIMAL WASTE UTILIZATION PLAN
*** This number must be less than or equal to 0 in order to fully
utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffers, filter strips along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than the
acres shown in the tables.
See attached map showing the fields to be used for the utilization of
animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient
rich and will require precautionary measures to prevent over application
of nutrients or other elements. Your production facility will produce
approximately 577.6 pounds of plant available nitrogen per year in the
sludge.
If you remove the sludge every 5 years, you will have approximately 3388
pounds of PAN to utilize. Assuming you apply this PAN to hybrid
bermudagrass hayland at the rate of 300 pounds of nitrogen per acre, you
will need 11.2933333333 acres of land. If you apply the sludge to corn at
the rate of 125 pounds of nitrogen per acre, you will need 27.104 acres
of land. Please be aware that these are only estimates of the PAN and
land needed. Actual requirements could vary by 255k depending on your
sludge waste analysis, soil types, realistic yields, and application
methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake.rate of the
soil at the time of irrigation such that runoff or ponding occurs. This
rate is limited by initial soil moisture content, soil structure, soil
texture, water droplet size, and organic solids. The application amount
should not exceed the available water holding capacity of the soil at the
time of irrigation nor should the plant available nitrogen applied exceed
the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables 1 and 2. Failure to apply the recommended rates and
Page: 6

ANIMAL WASTE UTILIZATION PLAN
amounts of nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application
rates and amounts.
Tract,
Field
Soil Type
Crop
Application Rate
(in/hr)
Applic. Amount
(inches)
840
1
CaB
BH
0.75
*1.0
840
3
CaB
BH
0.75
*1.0
840
5A
CaB
BH
0.75
*1.0
840
"1
SG
840
SG
840
"5A
SG
856
lA
CaB
BH
0.75
*1.0
856
SG
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations, the application amount shown cannot
be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180.00 days of temporary storage and the
temporary storage must be removed on the average of once every 6.00
months. In no instance should the volume of the waste be stored in
your structure be within the 25 year 24 hour storm storage or one foot
of freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply the
correct rates to the acres shown in Tables 1 and 2. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may
make this plan invalid.
Call your technical specialist after you receive the waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate prior to applying the waste.
Page: 7

ANIMAL WASTE UTILIZATION PLAN
NARRATIVE OF OPERATION
Page:

WASTE UTILIZATION PLAN
REFIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2.' There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
5. Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
G. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
B. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be considered.
Page: 9

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to
wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly into water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
the site.
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 10

• l .
WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
18. If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22. Waste shall be tested within 60 days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when these
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be
maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North
Carolina regulations.
Page: 11

't kill
vp
20
m
f
, 5".rk!•0
All4ve It — N
" ;l. ..
0
41
V.ljS,11. ji, Ws, ;. q
A lkh.
IN
Via
fpl.-
I
Y
0%�l"M3 Jr iiiYwt,
4L
iv'ry
7-k,
-F!
AR
W5
"T'r
XZA� 04
Ivor
S; rs
ca, C,
gni.,
, 51
- .
j
34i," ;-";- A�A
. ., ;, u , , WI.
, �• \A 114
mtwt
P
Ao
LZ ya
P4
N
-NA
I

+ J �
ANIMAL WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm:R & R Pork Farm
Owner/Manager Agreement
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
North Carolina Division of Water Quality (NCDWQ) before the new
animals are stocked. I (we) also understand that there must be no
discharge of animal waste from this system to surface waters of the
state from a storm event less severe than the 25-year, 24-hour
storm. The approved plan will be filed on -site at the farm office
and at the office of the local Soil and Water Conservation District
and will be available for review by NCDWQ upon request.
Name of Facility Owner: Richard Wood
(Please print)
Signature: Date:
Name of Manager(If different from owner):
Signature: Date:
Name of Person Preparing Plan: (please print)David G. Faircloth
Affiliation:NRCS Phone No. 910-875-8685
Address (Agency): 122 West Elwood Ave Rm 202
Raeford NC 28376-2800
Signature: . �CLL,*bL
Date: - J-.)-"
Page: 12

r4l
"-e
'ILI
4t
QV7 • eN-36
ri 47
lot
WO,
Nm
ty N 311
MAN"
WA A,
if tir
Vol
kin 1yia '42;
0 1'.
IM& RPM
w"i
Me, K�T
'4' n
4 1Y
0!4� VS 011" 11-11 <0 it"K
PA
. r
AN
:.'e "T
q'i
'i 'ji t-1 $4
NZ
Ike
Culp
j", p

•µ'off
�r !1, KIE77kiA'
.r
�a Ashley
r�Off Heights 110w, -
,tl 1 Gurre
177e
1226 -
r '* o Hru,lrh
y 4
P
""7e PICKLE 0 MILITARY RESERVATIC
► p
Flo127S y
lace
Jr Ashmont SANDY °ROVE CN �` \
a
r:
S1 1 0.O 1 7 7 3 Y t fa'.>!' j1 OTT
re a�gNK RD
► La
McCain ~ 1fF_'
1219
o pLAR11C RD
S 171r i D'
rn
'�- 1718 0 1719 Montrose L,hjP j
of'% 300
5 to k 1 71 5 / k*9 Jo"ON RD
1 ]�I
131e g �J Raiford
i ~
Municipal pe0 10
s
1714 711• o Airport ti t t.A
19
i
3 Fire Points SANIT 1739 ~ , ��♦1 Jk . s �+` 4inl a,•}Myeea
o
M0i'T4OSE wo `•LLO 4ATlllt3 f — \
I,1 17 r 1 I• ~A 7 No 3.1 SRO, t' P Y Fp 7 1 300 . I
13731`114NAVEIr DA
3)1
17r.
r.7 \ I StIvER C11'r
17'e wr •4L 1315 LAKE LINING AJk �I.1
Timberland ELI2ASETN 147e/
RD Silver 0 4ASON /! ALLE
Ciryl }1.T 1.60 ST � .k ST.
y * '1
fir*O40 Sound ' .� , r� 1496J
C /1 1 er t y ''+, `ir,. , 1497,) f
I N 1 a' • ..il:1t` `� UTRY v�107 I.Sf
r f,=7 &060 9 4y 11 3 -J rA5 1j ,I'j�_:. Old - .i
till LK� PO Pr '`'f ` eE�• N '*4Itr�f:r `.." t
k -; \�* r►' tusLrL! 4 •� F. "1,0 yi`.tl ip,fy:i,r r; •, I.De
a NORE y\ 0 170 i ctb k t 113 rAs l y ,7 1�:7 ^� y A 149
;`; ►� Buff m .+ n ( 1. ; 7 MORRISEI
A A. LAKE V e I U
r p Springs s 17D3 I �� RD �^ r.7 L irrf a '18r i� re,l l aa7 A
4 ;y -1 3+ • 1707 w I fl'•�yl� r5
-y�a M 711 J 7 j sr I.e]
ORIA
PD -s 1247 b
67 ►p 1 -tf- . 1. h1 Dw7 '11 � �1 '•'
.D J�. 1700 J 1707 re - I WARNER R ? - Act \ „ t i PAKDRLE GIN RD,
': ': �. _ \ O 1.03 y AA
170e
1707 } 1 1439 .D \� I0
0
3
J
low
1.' f Bethel 1Ia3 N. s 1 1 r A ,"
1u u
c ir1 1 1Sry�tr1 l� �; 114 o 'v 'N
..y',t "'1 • 1 '? ° J 6 .� . 741) q 5COT 143a I„5 t
PCVRRIE
• T 1433
Y-�dla�l• r 4 170. 90 1 BLUE+ a /r sr 1e POTTER AD w t.37 ^. I.e9R Low
1 t�•1" i� _ rr
lllll \ l
BOwmore SPl1fNG p 1 119 poky u '7 I a3e r
CLJFr• n 1 1 r: 1 1, e ' D 1 1.7 1 ° EEATTI1RO *LE' /
RNE! ) •�ry� .G y, 'a RD. A N 1�56a
GRAN" �111 _ d '+►•►t ,O 1115 7. Ss Cl1 6 1453
'fr s 6 'm NECr01t I. R0 1 1 r7 6 NEILL UAKWELL 6 L CN �p
Fs - . o ..RD
.ir rt,Ar 1 ;i�tl �s r 17
7 Mt a o Gold
�T° c7' b'P '' # 1`, y 00\ 1 1 f — ► f_ Hill M1
;M1S s 17°0 y 1171 p y( S 111. ?- HOKE-
V0 AO y 5 r tI]7 'c 10°I MCCORMICK 1434 ►
' 3 • BRANCH Mh RD `
Edinburgh e RD
n 3r41Sb 1
s� O 113,
.? 1.o
.2 1170 O 1170 'P, a LAUCILIH toot
do
. •j, l' a t 1101 L 7fq 01$e I toy ,
f:.�LLx ( 1 °� ft 11s. HOOGINS r OLD
.~ r°
�t ,fir, k✓ Vp�y7�, i ^ �' ` POND 711 NC 2 I 1 ,T' . •�
mgL o 1177
PD 7.d 11741124
3 ^ la]v �J -
' urcel t t Ck
CENTER
co ` ry GROVE cmmcN ♦ 'B .M1
•rT� 6 r A ?; 1176 1/\ Fn Esc �.... ti h I648

EMERGENCY ACTION PLAN wWfl'
RECEIVED
WATtR QLIA'_0Y SECT ION
PHON UMBERS 1998
D W %— S `'y/� 2 2
EMERGENCY MANAGEMENT SYSTEMy/,2�P
SWCD V& _ / A11 an-Dischcrge Permtttittg
NRCS Ss'?S Silo J-�'
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing, or running off site. You should not wait until wastes reach surface waters or
weave your property to consider that you have a problem. You should make every effort to
ensure that this does not happen. This plan should be posted in an accessible location for
all employees at the facility. The following are some action items you should take.
1. Stop the release of wastes. Depending on the situation, this may or may not be
possible. Suggested responses to some possible problems are listed below.
A. Lagoon overflow-- possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop al! flows to the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B. Runoff from waste application field —actions include:
n. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that caused the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinklers —actions include:
a. Stop recycle pump
b. Stop irrigation pump.
c, Close valves to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
D. Leakage from flush systems, houses, solid separators —actions include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure no siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
December 18, 1996

1
.®
e. Repair all leaks prior to restarting pumps.
E. Leakage from base or sidewill of lagoon. Often this is seepage as opposed to
flowing leaks —possible actions:
a. Dig a small sump or ditch away from the embankment to catch all seepage,
put in a submersible pump, and pump back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon
bottom as soon as possible.
2. Assess the extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what duration?
c. Any damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off of the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours, tali your DWQ (Division of Water Quality)
regional office; Phone fs6--1S17. After hours, emergency number: 1-800-858-0368.
Your phone call should include: your name, facility, telephone number, the details
of the incident from item 2 above, the exact location of the facility, the location or
direction of movement of the spill, weather and wind conditions, the corrective
measures that have been undertaken, and the seriousness of the situation.
b. If spill leaves the property or enters surface waters, call local EMS phone number-
T7s —'i .
c. Instruct EMS to contact local Health Department.
d. Contact CES, phone number _VS- 5'1W, local SWCD office phone number
and local NRCS office for advice/technical assistance; phone number 11K(a "/S ..
4. 1f none of the above works call 911 or the Sheriff's Department and explain your
problem to them and ask that person to contact the proper agencies for you.
5. Contact the contractor of your choice to begin repair of problem to minimize off -site
damage.
a, Contractor's Name: O- W il L.)(',C 1 'of so rL.�11 c -Q.
b. Contractor's Address: c 26 L, 17,eeS/C i�-' tA-
c. Contractor's Phone: 8.751— / 7 9 V
2 December 18, 1996

6. Contact the technical specialist who certified the lagoon (MRCS, Consulting
Engineer, etc.) !�
a. Name:
b. Phone; Tr 7�
7. implement procedures as advised by DWQ and technical assistance agencies to
rectify the damage, repair the system, and reassess the waste management plan to
keep problems with release of wastes from happening again.
3 December 18, 1996

VED
NIr� G k,i ION
�.
OPERATION AND MAINTENANCE FLAN
--------------------------------- Nonasci'b 'ge �armitting
This lagoon is designed for- waste treatment with minimum c-dor-
control. The time required for the planned fluid l"eve l to be
reached may vary due to soil tend i t i cans, f I ush i ng operations, and
the amount of fresh water- added to the system.
Land application of waste water' is recognized as an acceptable
method of disposal. Methods of application include solid set,
center- pivot, guns, and traveling gun irrigation. Care should tie
taken when applying waste to prevent runoff from the field or damage
to orrops.
The fc. I I owi ng i terns are 'to t-e care i ed out:
1. It is strongly recommended that the treatment I a9cion be pre --
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre--charg i rig reduce, the concentrat i -in of the in it i al
waste eater i ng the I agoor, to-iereby reduc i n3 odors. So I' i ds shou I d be
ccovered with effIuent at alI times.
2. The attached waste utiIizatior, pIan shaII be foIIowed . This
p I an recommends sarnp 1 1 ng and test i rig of waste ( see Attachment D)
before land application.
. Deg i n pump --taut of the I agoon when f l u i d I eve I reac hes e I eva--
t i on 90.D as marked by permanent markers. Step purnp-out when,
the fluid I eve l reaches elevation :36.0 or bef core f I u i d depth i s
less than 6 feet deep (this prevents the lass of favorable
bacteria) .
4. The rec ornmended mar, i murn amount to app f y per i rr i gat i rin i s
one (1) inch and the recommended maximum app I i cation rate is 0.4
inch per hour.
F. Deep vegetation on the ernbankment and areas adjacent to the
lagoon mowed annual l y. Vegetation should be fort i I i zed as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
outlets.
S. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.

Operator:Roy Word County: Hulse
Date:
09/0 /92
Distance to nearest residence (other-
than
owner) :
1000.0
feet
1. STEADY STATE LIVE WEIGHT
0 sows (farrow to finish)
x
1417
Ibs.
0
lbs
0 saws (f ar..row to feeder)
N
522
lbs. -
0
I bs
0 head (finishing only)
X
135
Ibs. -
0
Ibs
770 saws (farrow to wean)
>;
433
Ibs. =
r3-3410
1bs
0 head (wean to feeder)
>;
30
Ibs. -
0
lbs
TOTAL STEADY STATE
I._ I VE
WEIGHT
(SSLW) M
333 410
I b s
2. MINIMUM REQUIRED TREATMENT VOLUME
OF
LAGOON
Volume = 333410 lbs. SSLW >: Treatment Volume(CF)/Ib. SSLW
TreatmentVolurne(CF)/lb. SSLW= 1 CF/lb. SSLW
Volume = 232410 cubic feet
2. STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0.0 cubic feet
4. TOTAL DESIGN VOLUME
Inside top length 390.0 feet ; Inside top width 165.0 feet
Top of dike at elevation 92.0 feet
Freel: oaWd 1.0 feet ; Side slopes 3.0 : 1 ( Inside lagoon)
Total design lagoon I i qu i d level at elevation 91.0 feet
Bottom of lagoon elevation 80.0 feet
Seasonal high water table elevation 80.0 feet
Total design volume using prismoidaI formula
SS/END1 SS/ENDZ SS/SIDE1 SS/SIDE: LENGTH WIDTH DEPTH
3.0 3.0 3.0 3.0 384.0 159.0 11.0
AREA OF TOP
LENGTH * WIDTH =
384.0 159.0 61056.0 ( AREA OF TOP)
AREA OF BOTTOM
LENGTH * WIDTH =
318.0 93.0 29574.0 ( AREA OF BOTTOM)
)
AREA OF MIDSECTION
LENGTH * WIDTH * 4
351.0 126.0 176904.0 ( AREA OF MIDSECTION * 4 )
CU. FT. = [AREA TOP + (4*AREA MIDSECTION) + AREA BOTTOM? * DEPTH/6,
61056.0 176904.0 4.0 :1574.0 1 .
VOLUME OF LAGOON AT TOTAL DESIGN LIQUID LEVEL = 490479 CU . FT.

5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
390.0 165.0 64350.0 square feet
Buildings (reef and lot water)
Length * Width
0.0 0.0 0.0 square feet
TOTAL DA 642,50.0 square feet
Design temporary storage period to be 180 days.
5A. Volume of waste produced
Approximate daily product 1on of manure in CF/LL SSLW 0.0013,E
Volume = 333410 Lbs. SSLW * CF of Waste/Lb./Day * 180 day
Volume = 81421 cubic feet
SCE. Volume of wash water-
This is the amount of fresh water used for washing floors or voIum,
of fresh water used for a flush system. Flush systems that recirc+
the lagoon water are accounted for in 5A.
Volume = 0.0 gallons/day * 180 days storage/7.48 gal
per
Volume = 0.0 cubic feet
5C. Volume of rainfall ln'excess of evaporation
Use period of time when rainfall exceeds evaporation by largest am-
180 days excess rainfall - . 7.0 inches
Volume = 7.0 in * DA / 12 inches per foot
Volume = 37537.5 cubic feet

5D. VO I urne of ,'5 year - 24 hour storm
Vo I urne = 6.6 i riches / 12 i riches per foot * DA
Vol urne W 35392.5 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. Gi421 cubic feet
Pirt. 0 cub i c feet
5C. 375L:' cut• i c feet
5D. 35'393 cut, ic feet
TOTAL 154351 cubic feet
6. SUMMARY
Total required volume 487761 cutr i c feet
Total des ion vu Iurne avai I . 49047'.? cubic feet
Min. re.q. treatment volume plus sludge accumulation '_'::33410 cubic f
At elev. c6.0 feet ; Volume is 224424 cubic feet (end pumping)
Total design volume less ::5yr-24hr- storm is 455087 cubic feet
At elev. 90.3 feet ; Volume is 448534 cubic feet ( start pumping
Seasonal h i gf water- table elevation , 10.4 f t
7. DESIGNED BY: APPROVED BY:
DATE: 7� DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN

Nutrient Management Plan For Animal Waste Utilization
05-11-2001
This plan has been prepared for:
R & R Pork Farm
Richard Wood
4051 Aberdeen Road
Raeford, NC 28376
[phone]
This plan has been developed by:
Jeffery Brown
DSWC-FRO
225 Green Street
Suite 600 - •
Fayetteville, NC 28301
[phone]
Dev/o�/Xigndfure
Type of Plan: Nitrogen Only with Manure Only
Owner/Manager/Producer Agreement
r (we) understand and agree to the specifications and the operation and maintenance
procedures established in this nutrient management plan which includes an animal waste
utilization plan for Ihe farm named above. I have read and understand the Required
Specifications concerning animal waste management that are included with this plan.
Signature (owner)
Signature (manager or producer)
Date
Date
This plan meets the minimum standards and specifications of the U.S. Department of
Agriculture - Natural Resources Conservation Service or the standard of practices
adopted by the Soil and Water Conservation Commission.
Plan Approved By:4""5-1 c�
Tee finical Specialist Signature Date
---- - ----- - -
814190 Data Version 1.06 Date Printed: 05-11-2001 Cover Pa e

E7=M CVRDM.ERS: RAIIBIRD 90c,1313rx 713r
NU)MER OF SPRIN=L�S AVAH B u- 8
LEMM OF PIPE AV U-ABLE - 2700-FT OF 4-QKM ALIBADIUM
LEH= OF PIPE SEC170NS: 30`FT
wErl b D AbMTPR: 162-Fr
SPRUMSK SPAC INQ 90 X 90 FEET
smali+RPRESS17RE: ss-PSI
SPRRBU33gFLOW RATE: 443 GFM
MAX FLOW RATE OF A 4-INCH PLPELME- 200 GPM
TM NIIMSFR OF SPRIIiKIERS PER LRO£ 4
FLOW IIATE PER I BM 4 7C 443 -177 GPM
WEII ACRES AVanouru.41.01ACRES
LEGEND
0 erar>m An aprmma
® rmm
!� ssumaugr »num
A WILL
LL XdZ Shi* In ■ Rd ■d hTfpUm for the
R-19-ias ap—tian (A apar U farm).
- Y9
770 FARROW TO WEAN FACELXrY
4,158 LBS OF ANNUAL PAN PRODUCTION
FARM START DATE: APRIL '13, 1993
NpTE THIS IS LISTED AS ONE FI ZZ (U)
DN THE FSA NAP. FDD HAS EEM SEPARATED
FURTIgR FOR THE WUP AND IRRIGATION LAYOUT.
■ ■ rrr� �
■ ■ ■ errs*
..eaaaar--ra-�
a+�w a�� w-■ � r-w
AMINSTATE of NOIrM CAROUNA ROY & RICHARD WOOD, R&R PORK FARM ; �.... .••�•
nrA mR aI p mmomm au= m � momraa ar s a ar s*#
�.®� WETTABLE ACREAGE DETFR14IN:,?'.^'1 IE
� _ ,r 0"m y irDIS MUM �

W— W

J�
4�
tt Wolf qr'
POND �
s
ley
' gat*att Hahphrl *LSLv`V"tl014}0 � •
.13
x
u7e
•'� a � Brun,'A r
I,CKL77 p0 Z
MILITARY RESERVA
RD, 1 775
Y
~ r Ashmoast "MY GROVE CH e9 `
1776
0
J
J %JUTT
'S ypec� slj /\ PLANK RD LAKE
McCoin •
PL41VK
* V o Ln
,� 1711 , •� '`: 171• AAonhose �,Ib� - .
l + 300
r
RD 111 s •' ARR AO{NlOK RD
oy i �
h J 1316 a9 1701 r.i iaeford
! ~ -Fs i Municipal "fic
\5 71 a
,cV 211` Airport .f
a �
` Fire Points r NLo
lira 113t
WQV rROsf �D L.aq WTlerye '
� f 1y1111CN 'It i
eD, P J� e� y 1700 yr .1
K# 1377 /IMNAV[M r
4`,h 1 t71�r. Ayr✓'1'���� `'1�� .., '771. .J ! �
s
SIIviRGITY
1313 1) �r
LAKE NIN
b ; 9bp &• Timberland ELI[ABETK U ,'•• Ip/
RO Silver %A WION
iY. N o ' 131 a .J cityti ►+► t'aeo lr 1
v+r tav s
\\ V .• 40 Soundor I
• y `',1 + •.f
V
s0 13r 1 1713 V ' + `. '[.S!,e uslT IT'�ao7
eeRe s .' a Ofortl'
1713 ep
1707 7 .7 � turM►uni •L li+ .la0a
WE 110KE 170tas
a y BSprings
► 1103 RIl'4 .r `1 t a
{ rr1 r'1 r r t 3Pit
07. • . 'r1
I)s)�
!. �•/ 1O V�:\4 1300 PAS
I207 t16�1'i r WARKIIIIR RI7 ti'/01 tt iie O&KD LE dill AD.
1.0 1101/419
u y 1306 �( of V Ia03 20 L ARA
� v a r
1706 ~ 7707 ► \b '�►e" f�' V ta3� 'a r\ 1003 C.
o gy
Bethel rtai,'d ',' a �1rRarrrs
�Sr o V '1
lid
Ids# f,S t
•��1 1707 t1. Ids PcLRRItft
1134 1!'a ".Tian RD ' n "hE >Rt.33
it BLUE 'A o Ia37 n tall [k •
Bowmore S"I1a0 ^ 113v DOWN 7 1436 - '
► r V •) •0
1'�r `� . 'i 11 a• u y .P L I cICER6 �r
•' hfr� h . A I u/ BEATTt 'a[T
II7i 111r R�F ' , u
T; o r rr 'o RD. Y 1�at
'•' 't;1 � ^' AHAY'�, •r+
GRI171 " tONe4 1
�sarcr� o% }} 1147 ! KILL YA,II+ELL lass 1;11ACJ,
fteMINE IL -
1171 rt yO - 117a 3, 11 MOKE '4 O, Y G.
LUE R0 I137 :a '.' too' CORY1cx
AAA
j.134 RD lilt 174 15 Q� slot Edinburgh ? "1.0 \ !p o i.r 1.3 i n tall' /� I
- ..!.7i . ^ 1 b ..? 1170 ►RSMA
1170 1130 �4 / 'n.1 PH LAU07klk
• t - aG 4 ♦ 'rA[7 � 417 Rq 1
`.,, ;,. k•,'^ I 401 A► 1 101 J'`t11d !A Drl3pM 1101 ,
to ' 13a HODGINS.- ocD �,ti
1}ah;.oi} Purcal t11e .0 o tt77 'A CH 7.a 117a PON, zn 1vt1r
Glav I CKMCA

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
January 26, 1999
Roy & Richard Wood
R&R Pork Farm
4051 Aberdeen Rd
Raeford NC 28376
4 • •
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Certificate of Coverage No. AWS470031
R&R Pork Farm
Swine Waste Collection, Treatment,
Storage and Application System
Hoke County
Dear Richard C. Wood:
In accordance with your application received'on October 22, 1998, we are forwarding this Certificate of
Coverage (COC) issued to Roy & Richard.Wood, authorizing the operation of the subject animal waste
collection, treatment, storage and land application system in accordance with General Permit
AWG100000. This approval shall consist of the operation of this system including, but not limited.to,
the management of animal waste from the R&R Pork Farm, located in Hoke County, with an animal
capacity of no greater than 770 Farrow to Wean and the application to land as specified in the Certified
Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC, you
are authorized and required to operate the system in conformity with -the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modiftcatiori to. the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This request
shall be made within 30 days of notification by the Division.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the DWQ prior to a name change or change in ownership.
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Certificate of Coverage AWS470031
R&R Pork Farm
Page 2
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual non -discharge permit by contacting the engineer listed below for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
The subject farm is located in the Fayetteville Regional Office. The Regional Office Water Quality Staff
may be reached at [phone]. If you need additional information concerning this COC or the
General Permit, please contact Sue Homewood at [phone] ext. 502.
Sincere
,/A. Preston Howard, Jr., P.E.
M. (Certificate of Coverage only for all cc's)
Hoke County Health Department
Fayetteville Regional Office, Water Quality Section
Hoke County Soil and Water Conservation District
Permit File
NDPU Files

OPERATION AND MAINTENANCE FLAN
------------------------------
Th Is I ascion is des i gr,ed f-or waste treatment w i th m i n i mum codc,r-
contr o 1 . The time required for- the planned f l ui d l eve l to tie
reached may vary due to so i I cc,nd i t i ono, f I u s h i na oper-at i oris, arrd
the amount of fresh water- added tog the system.
Land application of waste water- is recognized as an acceptable
method of disposal. Methods -if application include solid set,
center pivot, guns, and traveling gun irr13atlon. Care should be
taken when applying waste to prevent runi7ff from the f i e I d or damage
to craps.
The following items are to be carried out:
1. It is str•on3Iy recommended that the treatment Iasvon tie pre -
charged to 1/Z its capacity to prevent excessive ciders during
start-up. Pre -charging reduces the concentration of the initial
waste enter 1ng the Iagoon thereby reducing odors. Sri Iids shouId tie
covered with effluent at a I I times.
2. The attached waste utiIization plan shalI tie followed. This
plan recommends samp11n3 and test Ing cif waste (see Attachment D)
befwre Iand app11cat ion.
. Begin purrtp-cut of the Ia3ac+n when fluid Ieve I reaches eIeva-
t i --on 90.3 as marked by permanent markers . Step pump -out when
the f l u i d I eve i reac hes e I evat i.:in 86.0 or before f l u i d depth i s
less than 6 feet deep (this prevents the I oss o-F ,favorab I e
bacteria) .
4. The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended maximum application rate is 0.4
Inch per hour.
5. Keep vegetation or, the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorau5 stand.
6. Repair any eroded areas or- areas damaged by r o"dents and
establish in vegetation.
7. All surface runoff is to be diverted from the la3oan to stable
outlets.
The Clean Water- Act of 1977 prohibits the discharge cof
pollutants into waters of the United States, The Department of
Environment, Health, and Natural Resources, Division cif Environ-
mental Management, has the responsibility for- enforcing this Iaw.

11. The Groundwater Compliance Boundary for the disposal system constructed after
December 31, 1983, is established at either (1) 250 feet from the waste structures and
from the waste disposal area, or (2) 50 feet within .the property boundary, whichever is
closest to the waste structures and the waste disposal area. If this facility was constructed
prior to December 31, 1983, the Compliance Boundary is established at either (1) 500
feet from the waste disposal area, or (2) at the property boundary, whichever is closest to
the waste disposal area. An exceedance of Groundwater Quality Standards at or beyond
the Compliance Boundary is subject to the requirements of 15A NCAC 2L and the
Division in addition to the penalty provisions applicable under the North Carolina
General Statutes.
This General Permit issued the eighteenth day of May, 1998.
NORTH CAROLINA ENVIRONMENTAL MANAGEMENT COMMISSION
A. Preston Howard, Jr., F% ector
Division of Water Quality
By Authority of the hnvironmental Management Commission
Swine Waste General Permit Number AWG100000
7

Operator:Roy Wood County: Huge Date: 09/02/92
Distance to nearest residence (other than yawner): 1000.0 feet
1. STEADY STATE LIVE WEIGHT
0
saws
(farrow to
finish)
x
1417
lbs.
- 0
lbs
0
saws
(farrow to
feeder")
x
522
lbs.
= 0
lbs
U
head
(finishing
only)
x
1•35
lbs..
= 0
lbs
770
sows
( farrow to
wean)
>:
433
1 bs.
- 33341f3
1 Lis
0
head
(wean to feeder)
>t
30
lbs.
- 0
lbs
TOTAL STEADY STATE LIVE WEIGHT (SSLW) _ 333410 i b s
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 333410 lbs. SSLW r, Treatment Volume(CF)/Ib. SSLW
'Treatment Volume(CF)/Ib. SSLW= 1 CF/It. SSLW
Volume = 333410 cubic feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0.0 cubic feet
4. TOTAL DESIGN ��Vi iLUME
Inside top length 390.0 feet ; Inside tap width 165.0 fee`
Top of dike at elevation 92.0 feet
Freeboard 1.0 feet ; Side .stapes 3.0 : i (Inside lagoon)
Total design lagoon liquid level at elevation 91.0 feet
Bottom of lagoon elevation 50.0 feet
Seasonal high water table elevation 80.0 feet
Total design volume using prismoidalRformula If
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH WIDTH DEPTH
3.0 3.0 3.0 3.0 304.0 169.0 11.0
AREA OF TOP
LENGTH * WIDTH =
384.0 159.0
61056.0 ( AREA
OF TqP )
AREA OF BOTTOM
LENGTH * WIDTH =
318.0 73.0
29574.0 (AREA
OF BOTTOM)
AREA OF MIDSECTION
LENGTH WIDTH * 4
351.0 126.0
176904.0 (AREA
OF MIDSECTION 4)
CU. FT. = [AREA TOP +
(4*AREA MIDSECTION)
+ AREA SOTTOMI
61056:0
176904.0
29574.0
V�
DEP 0,
7LUME OF LAGOON AT TOTAL DESIGN LIQUID LEVEL = 490479 CU., I

s
5. TEMPORARY STORAGE REQUIRED
CL
DRAINAGE AREAa
Lagoon (top of dike)
Length * Width a
390.0 165.0 64350.0 square,f.eet
Buildings (roof and lot water)
Length Width
0.0 0.0 0.0 square feet
TOTAL DA 64350.0 square feet
Design temporary storage period to.be 180 days,
5A. Volume of waste produced
Approximate dal.ly production of manure in CF/LLB SSLW 0.001136
Volume - '333410I-bs.. SSLW CF of Waste/Lb. /Day
Volume = 814ZI cuts i c feet
5B. Volume of wash water
This Is the amount of fresh water used for washing floors or vo'li
of .fresh water used for. a f'I ush system. F lush systems . that rec i ;
the lagoon water are accounted,for In 5A.
Volume p. 0.0-gallons/day 100 days storage/7.48, 9;
Volume 0.0 cubic feet
5C. Volume of rainfall In excess of evaporation
Use period of time when rainfall exceeds evaporation by largest
130 days excess rainfall - 7.0 inches
Volume = 7.0 In * DA / 13 inches per foot
Volume = 37537.5 cubic feet

5D. Volume of 'Z5 year - 24 hour- storm
Volume = 6.6 inches / 12 Inches per foot * DA
Volume = 35392.5 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 314Z1 cubic feet
5B. 0 cubic feet
5C. 37533 cubic feet
5D. 3SP93 cubic feet
TOTAL 154351 cubic feet
6. SUMMARY
Total required volume 437761 cubic feet
Total des!3n volume avail. 490479 cubic feet
Min. req. Aeatment volume plus sludge accurrtuIation 3,33410 cubic
At elev. 86.0 feet ; Volume is 224424 cubic feet (end pumping
Total deslgn volume less 25yr-34hr storm is 455087 cubic feet
At elev. 90.3 feet ; Volume Is 44S534 cubic feet (start-pumpii
Seasonal hi g water table elevation 30.0 f t
7. DESIGNED BY: A% APPROVED
DATE: DATE:
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN

�Av
NCI R
North Carolina Department of Environment and Natural Resources
Pat McCrory
Governor
Richard C. Wood
R&R Pork Farm
4051 Aberdeen Road
Raeford, NC 28376
Dear Richard C. Wood:
John E. Skvarla, III
Secretary
December 11, 2014
Subject: Certificate of Coverage No. AWS470031
R&R Pork Farm
Swine Waste Collection, Treatment,
Storage and Application System
Hoke County
In accordance with your Notification of Change of Ownership and renewal request December 8, 2014, we
are hereby forwarding to you this Certificate of Coverage (COC) issued to Richard C, Wood, authorizing
the operation of the subject animal waste management system in accordance with General Pert -nit
AWG 100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for R&R Pork Farm, located in Hoke County, with a swine animal capacity of no greater
than the following annual averages:
Wean to Finish:
Feeder to Finish:
Boar/Stud:
Wean to Feeder:
Farrow to Wean: 770
Gilts:
Farrow to Finish:
Farrow to Feeder:
Other:
If this is a Farrow to Wean or Farrow to Feeder operation, there may be one boar for each 15 sows. Where
boars are unnecessary, they may be replaced by an equivalent number of sows. -Any of the sows may be
replaced by gilts at a rate of 4 gilts for every 3 sows.
This COC shall be effective from the date of issuance until September 30, 2019, and shall hereby void
Certificate of Coverage Number AWS470031 dated October 1, 2009: Pursuant to this COC, you arc
authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please read this COC and the enclosed State General Permit carefully. Please pay careful attention to the
record keening, and monitorin r conditions in this permit. Record keeping, forms are unchanged with this
General Permit. Please continue to use the same record keeping forms,
If your Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
1636 Mai! Service Center, Raleigh, North Carolina 27699-1636
Phone: [phone] Internet: www.ncdenr.gov
An Equal Opportunity V Attirmalive Action Employer — Made in part by recycled paper

The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Per NRCS standards a 100-Foot separation shall be maintained between water supply wells and any
lagoon, storage pond, or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Pernlit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive reliet'.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Program for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition I1.22 of the General Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Tropical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You
may find detailed watch/warning information for your county by calling the Raleigh, NC National
Weather Service office at [phone], or by visiting their website at: http://www.weatlier.gov/rah/
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office staff
may be reached at 910-433-3320. If you need additional information concerning this COC or the General
Permit, please contact the Animal Feeding Operations Program staff at [phone].
Sincerely,
for Thomas A. Reeder
Director, Division of Water Resources
Enclosure (General Permit AWG100000)
cc: (Certificate of Coverage only for all ecs)
Fayetteville Regional Office, Water Quality Regional Operations Section
Hoke County Health Department
Hoke County Soil and Water Conservation District
WQROS Central Files (Pen -nit No. AWS470031)
AFO Notebooks TEk
Ernest Smith Farm Inc IrrIVE 0
DEC 16 2014
oivls&11;F vvA;T' N14AGEMENT
=`VI? I E ficGl0f Al OFFICE
FAYETT

7
Nutrient Mann etnent Plan For Animal Waste Utilization MO
g o A. I
05-11-2001
This plan has been prepared for:
R & R Pork Farm
Richard Wood
4051 Aberdeen Road
Raeford, NC 28376
[phone]
This plan has-been developed by:
Jeffery Brown
DS;V(,;.FRO
22S Greet Street
Suite 600 . .
Fayetteville, NC
[phone]
t7c�' o ignR�urt
Type of Plan: Nitrogen Only with Manure Only
RECE1'��
AUG 2 0 M
�301
MR-FAYEMLLE PH,
OFvner/Manager/.t'roducer Agreeincnt
I (ire) understand and agree to the specifications and the operation and mainterianct!
procedures established in this nutrient managetneut playa which includes an aninnal waste
utilization Man forlhe farm named above. I have read -and understand the Required
Specifications concerning animal waste munagennent that are included with this plan.
Signature (owner)
Signature (manager or producer)
Date
Date
This plan meets the minimum standards and specifications of the U.S. Department of
Agriculture - Natural Resources Conservation Service or the standard of practices
adopted by the Soil And Water Conservation Commission.
Plan Approved 13y: /•
Te finical Specialist Signature Date
----- --'---..-.----------------------------------d: 05-11-2001 Cover Past: I
RECEIVED I DENR I DWQ
AQINFFR'PRnTFr-71nN.RFCTiON
AUG 17 2009
M

Nutrients applied in accordance with this plan Nvill be supplied from the
following source(s):
Commercial Fertilizer is not included in this plan.
S9
Swine Farrow in -Weanlin La oon Liiquid waste generated 2,466,310
gals/year by a 770' animal Swine Fan-owin •-Weanling Lagoon Liquid
operation. This• roduction facility•has waste storage Capacities of
a roximatel l80 days.
Estimated Pounds of Plant Available Nitrogen Generated per Year
Broadcast
3808
Incorporated
6540
Injected
7202
Irrigated
4139
Actual PAN applied
Year 1
9760
dotes:
In source ID, S Tnc:ms standard source, U ineans user defined source.
-.. - - - - -- -- -- ------------•------
S 14 190 Database Version 1.06 Date Printed: 05-1 1-2001 Source Pa' e I

The Waste Utilization table shown below summarizes the waste utilization plan for this operation. This plan provides an estimate of the number of acres of
cropland needed to use the nutrients being produced. The plan requires consideration of the realistic yields of the crops to be grown, their nutrient requirements,
and proper timing of applications to maximize nutrient uptake.
This table provides an estimate of the amount of nitrogen required by the crop being grown and an estimate of the nitrogen amount being supplied by manure or
other by-products, commercial fertilizer and residual from previous crops. An estimate of the quantity of solid and liquid waste that will be applied on each field
in order to supply the indicated quantity of nitrogen from each source is also included.
A balance of the total manure produced and the total manure applied is included in the table to ensure that the plan adequately provides for the utilization of the
manure generated by the operation- Animal operations that generate liquid waste and utilize waste storage facilities (lagoons or holding ponds) may apply more or
less waste in any given year than is annually generated by the facility. In order to determine whether the plan adequately utilizes the waste produced by the
facility, the storage capacity table included in this plan should be reviewed to ensure that the design capacity of the storage facility is not exceeded during the
planning period.
Depending on the requirements of the crop and the nutrient content of the waste, some nutrients %vill likely be over or under applied if animal waste is being
utilized. Waste should be analyzed before each application cycle and annual soil tests arc required if animal 'waste is being applied. Soil tests should be used to
balance the nutrient application amounts with the realistic yields of the crop to be gnown. Nutrient management plans may require that the application of animal
waste be limited so as to prevent over application of phosphorous when excessive levels of this nutrient are detected in a field -
Waste Utilization Table Year 1
Tract
Field
Source
1.1).
Soil Series
'total
Acre
Use.
Acres
Croli
RYP
RYE-
Unit
Appiic-
Period
Nitrogen
PA
Nutriem
Req'd
(lb,JAOda)
Comm.
Fell
Nutrient
Applied
Res.
(lbs/A)
N
Applic.
Method
Manure
PA
Nutrient
Applied
Liquid
Manure
Applied
(acre)
Solid
Manurc
Applied
(acre)
liquid
Manure
Applied
(Field)
Solid
Manure
Applied
(Field)
N
N
1bs/A
1000
eallA
tons
1000 eats
tons
S40
1
S9
Candor
16.9
9.5
Small (train Overseed
1.0
Tons
1011-3131
50
0
0
brig.
50
14.9
0.0
141.4
0.0
840
1
S9
Candor
16.9
9.5
i3crmuda,rass Pasture
`5.0
Tons
311-9/30
188
0
0
Img.
188
112.0
0.0
1,063.0
0.0
840
3
S9
Candor
10.4
4.5
Sma11 (ir'ein Ovmced
1.0
Tons
1011-3/31
So
0
0
brig-
50
29.8
0.0
132.9
0.0
8,0
3
59
Candor
to s
4.5
liernudattrass Pasture
•5.0
Tons
3/1-9/30
198
0
0
Img.
189
112.0
0.0
499.6
0.0
I
SA
S9
Candor
19.6
5.3
Small Grain Overseed
1.0
Tons
1011-3131
50
0
0
Img.
50
29.9
0.0
157-6
0.0
S40
5A
S9
Candor
Ian
;.3
13rrnu dnarass Pasture
•5.0
"runs
3li Jl30
188
0
0
img.
188
112.0
0-0
592.6
0.0
850
I
S9
C,and"I
7.8
7.9
Small Grain Oversec'd
1.0
Tons
10/1-3131
50
0
0
in-i ,.
50
i9.8
0.0
232.7
0.0
ti56
IA
S9
('andor
7.ti
7.8
1lcnzwc3a•_rass l'asturc
`5.0
liras
3/1-91}()
198
0
0
Ime_
I%F
112.0
0.0
874.9
0.0
856
It3
S9
Candor
7 0
7,0
Snlail Gir iin Oversccd
1-0
Tons
10/1-3/31
50
0
o
irrig.
i0
29.8
0.0
2t)7 9
o.(I
SIA190 Dwihasr Version 1.06 Daic hinlej: 05-11-Mol AV1jT pad-e I

Waste Utilization Table
Year l
Tract
Field
Source
i.D.
Soil Series
Total
Acre
Use.
Acres
Crop
RYF,,
RYE
Unit
Appl"se.
Period
;Nitrogen
PA
Nutrient
Rcq'd
Ih
Comm.
Fert.
Nutrient
Applied
1
Res.
(lbslA)
N
Applic_
Method
Manure
PA
Nutrient
Applied
Liquid
Manure
Applied
(acre)
Solid
Manure
Applied
(acre)
Liquid
Manure
Applied
(Field)
Solid
Manure
Applied
(Field)
N
N
lbs/A
1000
eallA
tuns
1000 vats
tons
956
IB
S9
Candor
7.01
7.0
BermudagrassPast—
•i()
'tbns
311-9130
" 138
0
0
hri .
in
1[2.0
0.0
781.9
0.0
856
1C
S9
Candor
7.0
7.0
Small Grain Overseed
1.0
'Pons
10/1-2
SO
D
D
lrri .
50
29.8
0.D
207.9
0.0
856
le
S9
Candor
7.0
7.0
Bermudaarass Pasture
'5-0
Tons
3/1-9/30
188
0
0
lrri;.
]fib
112.0
0.0
781.9
0.0
Lagoon Liquids
Total Applied, 1000 gallons
5,673
Total Produced, 1000 gallons
2,466
Balance. 1000 gallons
-3.208
Manure Solids
Total Applied, tons
0
Total Produced, tons
0
Balance, tons
0
Notes: t . in the tract column, symbol —means leased, otherwise, owned. 2. Symbol • means user entered data.
------------------------------------------- -----------------------------------------e ----------
914190 Database Version 1.06 Date Printed: 05-11-2001 WUT Pa 2

The Irrigation Application Factors for each field in this plan are shown in the following table.
Infiltration rate varies with soils. If applying waste nutrients through an irrigation system, you must
apply at a rate that will not result in runoff. This table provides the maximum application rate per Dour
that may be applied to each field selected to receive wastewater, It also lists the maximum application
amount that each field may receive in any one application event.
Irrigation Application Factors
'rract
Field
Sail Series
Application )laic
(inches/hour)
Apphruiun AMOLIM
(inches)
840
1
Candor
0.75
0.48
840
3
Candor
0.75
0 48
840
5A
Candor
0.75
0.48
856
IA
I Candor
0.75
OAS
856
113
Candor
0.75
0 4ti
856
IC
Candor
0.75
0 13
------ ------------------
814190 Database Version 1.06 Date Printed: 05-11-2001 lAF Page 1

Narrative
l+ields I &:, I are secondary fields in the WUP. The farm has enough acreage without these two fields,
however owner wanted fields in WUP. Therefore, these two fields are not required to be overseeded
with small grain for winter application.
------------•------------------------------------
81419fl Database Version 1.0( Date Printed: )5-1 1-2001 Narrative Pa e 1

The Available Waste Storage Capacity table provides an estimate of the number of days of storage
capacity available at the end of each month of the plan. Available storage capacity is calculated as the
design storage capacity in days minus the number of days of net storage volume accumulated. The start
date is a value entered by the user and is defined as the date prior to applying nutrients to the First crop in
the plan at which storage volume in the lagoon or holding pond is equal to zero.
Available storage capacity should be greater than or equal to zero and less than or equal to the design
storage capacity of the facility. If the available storage capacity is greater than the design storage
capacity, this indicates that the plan calls for the application of nutrients that have not yet accumulated.
If available storage capacity is negative, the estimated volume of accumulated waste exceeds the designs
storage volume of the structure. Either of these situations indicates that the planned application interval
in the waste utilizatian plan is inconsistent with the structure's temporary storage capacity.
Available Waste Storage Capacity
Source Name
I Swine Farrowing-Weanling Lagoon Liquid
Design Storage C.Ipacity (Days)
Star! Date
9/36
180
Plan Year
Month
Available Storage Capacity (Days)
1
1
165
1
2
ISO
1
3
ISO
l
4
ISO
1
5
[so
1
6
ISO
1
7
ISO
1
8
1s0
1
9
ISO
l
10
170
1
11
17�
1
12
158
Available Storage Capacity is calculated as of the end of each month.
--------------------------------------------------------------- -- -� -
814190 Database Version 1.06 Date Printed: 05-11-2001 Capacity Page !

' Crop Notes
.The following crop note applies in licid(s): 1, IA, 111, I C. I. 5A
Small Grain; Coastal Plain, Mineral Sail, highly leachable
In the Coastal Plain, oats and barley should be planted from October 15-October 30; and ryQ from
October 15-November 20. For barley, plant 22 seed/drill row foot and increase the seeding rate by 5% for
each week seeding is delayed beyond tl!:e optimum time. See the seeding rates table for applicable
seeding rate modifications in the current NCSU "Small Grain Production Guidc",.:.Also, increase the
initial seeding rate by at least:10% when planting no -kill. Oats should be'. 'planted at 2 bushels/acre and
rye at 1-1 1/2 bushels/acre. Plantall these small grains at 1-1 112" deep. Adequate depth control is
essential. Review the NCSU Official Variety "green hook" and information from private contpani�..s rc,
select a high yielding variety with the characteristics needed for your area and conditions. Apply no more
than 30 lbs/acre N at planting. Phosphorus recommended by a soil test report can also be applied at this
time. The recommended rate of potash should be split with 1/2 applied at planting and the other 1'2
applied when the N is topdressed in the Spring, The remaining N should be applied during the months oi'
1,ebruary-March. The total N needed is dependent on the soil type. Apply sulfur at the rate ol' S 1bs:'acrc it
planting and another 20 lbs/acre with the topdress N. Plant samples can be analyzed during the grow11111
season to monitor the nutrient status of the oats, barley and rye, Timely management of diszases, insrcts
and weeds are essential for profitable oat, barley and rye production.
The following crop note applies to fieid(s): 1, 1 A, I B, 1 C, 3, 5A
13ermudagr•ass: CP, Minerral Soil, Well Drained to Excessively Drained
Adaptation: Weii-adapted.
In the Coastal E5Iain, hybrid bermudagrass sprigs can be planted Mar. Ito Mar. 31. Cover sprigs l" to
deep (1.5" optimal). Sprigs should be planted quickly after cligging and not , llowcd to dry in sun ,tnd
wind. For Coastal and Tifton 78 plant at least 10 bu/ac in 3' rows, spaced 2' to 3' in the row. Gcnernlly H
rate of 30 bu/ac is satisfactory.to produce frill groundcover in one or two years under good groNvrng
conditions. Tifton 44 spreads slowly, so use at least 40 bu/ac in 1,5' to 2' rows spaced I' w 1.5' 1:1 1,0W.
For broadcast./disked-in sprigs use about 60 bu/ac. Soil test for the amounts of lime, phosphorus,
potassium and micronutrients to apply preplant and for annual maintenance: Sulfur will be n!edt d uii
deep sands with high leaching, Apply 60 to 100 lb/ac N in the establishment yetsr in split applications in
April and July. For established stands apply 130 to 240 lb/ac N annually in split applications, usually in
April and following the first and'second hay cats. For better soils the N rate can be increased to 300
lb/ac, Reduce N rates by 25%.for grazing, Referto NCSU Technical Bulletin 305 Production and
Utilization of Pastures and Forages in North Carolina for more information or consult your regional
agronomist or extension agent for assistance,
.........................................................................I...
K 1 a i94 patabase Version 1 A( Date Printed; 05-1 1-2001 Crop1ur�!

Th; following Lagoon Sludge Nitrogen Utilization table provides an estimate of the numb r ofarres needed fc,r
sludge utilization for the indicated accumulation period. These estimates are based on average nitrogen
concentrations for each source, the number of animals in the facility and the plant available nitrogen applic-n1ion
rates shown in the second column.
Lagoon sludge contains nutrients and organic matter remaining after treatment and application of the effluent. At
clean out, this material must be utilized for crop production and applied at agronomic rate;. In most cases, the
pri)rity nutrient is nitrogen but other nutrients including; phosphorous, copper and zinc can also be limiting. Since
nutrient levels are generally very high, application of sludge must be carefully applied.
Sites must first be evaluated for their suitability for sludge application. Ideally, effluent slxay [gelds should not he
used for sludge application. If this is not possible, care should be taken not to load effluen: application fields with
high amounts of copper and zinc so that additional effluent cannot be applied. On sites vulnerable to surfncr water
moving to streams and lakes, phosphorous is a concern. Soils containing very high phosphorous levels may also bk�
a concern.
Lagoon Sludge Nitrogen Utilization Table
Crop
Maximum I
PA-N Rate
lblac
Maximum Sludge
Application Rate
1000 gallao
Minimum Acres
5 Years Accumulation
Minimum Acres
10 Years Accumulation
Minimum Acres
15 Years Accumulation
Swine Farrowing-Weanling Lagoon Sludge - Standard
Corn 120 bu
150
13,161
22.82
45.631
08A5
Nay 6 ton RICH.
300
26.32
11,41
22.821
3 4.2 2
Soybean 40 bu
160
14.04
21.39
42.75
4.17
----------------------------------------- --------- ................
814190 Database,Version 1.06 Date Printed: 05-11-2001 Sludge I aue I

E)OSMG SPRIMMEM RAINBIRD 80C, 13/32' X 7132'
NUMBER OF SPRDM EIS AVAILABLE: B
LENGTH OF PIPE AVAILABLE- 2700-Fr OF 4-INCH ALUM NUM
LJWGTH OF PIPE SECITONS: 30-Fr
WETTED DIAMETEM 162-Ff
SPRWSI.F.R.SPACING: 90 X 90 FEET
SPRI24XIEA PRESSURE: SS -PSI
SPRINKLER Flow RATE-. 44,3 GPM
MAX FLOW RATE OF A 4-INCH PTA !*E- 2W GPM
THE NUMBER OF SPR41LCI F.RS PER LINE: 4
FLOW RATE PER 'UNE 4 X 443 - LTl GPM
WE= ACRES AVAILABLE: 41.01 ACRES
LEGEND
--------- FZNCZLaaa
0 ssAS>a CM OPMOC =
9 raa
B TDwaaAer E00FC231A1a
9 •EZ
L Kota; This is solid set hTtgation for the
finiahiat Operation (a separate farm).
770 FARROW TO WEAN FACILITY
4,156 LBS OF ANNUAL PAN PRODUCTION
FARM START DATE: APRIL 13, 1993
NOM THIS IS LISPED AS ONE FIELD (1A)
ON THE F5A MAP. FIELD HAS BEEN SEPARATED
FURTHER FOR THE WUP AND IRRIGATION LAYOUT.
kehSTATE OF NORTH CAROLINA ROY & RICHARD WOOD, R&R PORK FARM „ wn
O arvm=% m=m lm xm@ m
oil_ ,W, �," � F!TABLE ACREAGE DETERbIr_N
HOKE

+1 G _ .'' i!. Y,`��,e1 S�'i �:..:. 'tF�Y�'N'•'rfntiS' ,.� ]4 ;..r.. " W •' f r s
.�r� • n. , „•' ftir � \ . 1�1 r a�iy,��..�i...r+'�i"I .•:, , .. ��� .: .R. ! ..as. r,ryP,p�..,� .+.ri •` 1 •;+.
I ' i � J�' t'yr i '' j.l. .. ��yv>c --, Ir L � ' � � �.' - �t 'YS��,M �;�1, � +V �,f - ,•, �.
r.i',�^ ++t�i�•�t!� �Y �E,ly>y�•• � ,`� 1 -I t >��c i���.�_'=�1 \ ' � � � � ';` :''� ' .'/' r r , Y ,iS(�'
t r r�v, ,.
�W,1ti
''•'• i' r4�t t ���_,r!1 I > �l •`, �.��.`/—•.� .� �1 ` l},•"� ^� A f • � �.:.
vile w C
}L y _S` J+t_ti4 S` , .Y �� ! �r.r '+i: rr� �� >�s i/, v.J•^.!ilti h¢ .t.
Vx
.. 1f1�ti1't'r11,,.7��- y„ ,y1 �J1 fi,•iF,� •y,.. y V. � �' ''; � : ! a•� i e'V��, `Y t�
Y` y} V ti ,'a .n� �2., j!clrf-°$`•'f . �'�, � .. .. +, F, a,`�,� �'�., ,'� /?%� �� 1, ,r:�ti c v ��. iii
._ ' �, •• I`s I :ts 1'' 4V iV t,�� �k'--�, r � ��' .1- rt .fr 1 �.;.
. ' i 1 r' -' 4 •• 1 � ��. Y'v , f t — •` 'y •�, ,`.� : �r Yrw' v � �r.�j-j�yis` 7.tr �
i �.i.+� •, Mti�.^ S�. l��yl�1i�i4+1 i'y� F t� `��1 I •, f t Sr;" i , �/ � �: �YJ.
rtAU t,'k'rs „s ►nd'' r'r r 4�, 4 F .�'nnY r ; i1• f�a , ' "/ ,t. �`�..
.,� • �r,;r1�`;ry��.}J;N s. 1 }: Sit:. - iGtiiJJ, �1ip ����! s • I'' ' :t ., fc `! i 1 .�� 1�'.+, .:
_�. �a�Fnt:_ ;�.. +1•." '."F�•►�',�,f, ,` f� i 5 � , r,t�i:- •,'` ' 'I •L�• ��, � ���+ .7� F
. •f, Y, }:j �.f. - 4''� ;,r,* � - f�';, rye,'•' � %i' � Y- t , F.}� 31' R;•T�,� 1
.'�.ry .},�,lr=^,'s� .�>,' `V.�f,�..'•' �a/�)' � � r + � iAV
� '31.•'i.�••� i Pyii
AV
1" r.��,1' Y•� F I r ii iy - t[��`y f —i;' •*�'��,}V'• J�t'}
.It , . •�, .5S., js {rt�yy A . rf �l i..y,'�t �' �� {4, L +F+,r .., `� v�L!}. � � } { � �i
` ty.. ): t t � T SLY -r ,., � „V C `J i'I�•. � `�Y yy��. JJAA���• �1 ti -.1i(� ` ` �)
`y3 1 x �tr�, 4 �'.'� t+' '.r� �#,�{,� t �4,�•.�� �CTT i`1111•' •� y' � L
ALI ' T
. vi h. i'!}� + `'r� i, F..l, •r U"u L'rt
� , h
';,��5�; �'''Knw.. S,� ' L• �..Z I ;�r�f i 7
Xr1 'Ya1 • ��y+Or'=^F ��
. _: *.i - y �§ t.+,[• jr �' _ ' 1 P i};pr �I, ' , y�;�tti:^ 'Y;r° . C,.`' J F � - r� , L ^ d+ '�/• y, �js
1'I tr Y'� _ f Y �� > is �,~iF 1'� �zr�.t 7'„•Y •� `�.i ?� i r f' Y 'V `. �f/�I \\ i Y ° jU1>!wrd
;.4,,, � } �' ��' ✓ y�.i'�, � •J'�z�tr.,+} a � :"� 3 Zr.r :?; t6�? t � � \•'l / � r,' P �S({t�r t'r�i ",�
' �• L ;yar:,t,y;�'� ' sg �, ,} rR l� r1y ,rti - # �� Ir�vrw
W
,� }r', a i � "tNx
1 SS jF
��
:{� roc ✓, ty,wW.�tr r , � n.`1+ it 4 't.3tfd ••:}i ,}f :.�y'�[}'-�K J i'.`.tYi,.)t��.`•Yi' yl •� ` � '� �,' • J t.x 1
I,� e � `rJ - .., . �`,.r. i � `;tir `�. I \T F.,Kr.k 4!n„'f'a'�,t1�if'�tk3�;.;a,•-.>1-:']/" it ,'�r `. „• '' �,h`1 3c..•,' , ,+ �'.
v�',1 I\ 1' u •�, b/ -JZ� - Slru+1 '+'y,,. •4. N ,w.'� a �� � �n it
. } *' C � ✓� 1 '! n 1 � A17 ��s'.� � ,fir 4 L��a j �� f �I// r ! C � - �' .
, �7.:f it�'li 1;1 �' .�.' � t '. � �' ;�iR �j� `r 1,11?�' }.y"`~T���nF'�;}�• . I1 y1�!'1 �, ���, � 0 r � -
�. S��y��'� ` ,' 'y. 1, A y '<<�ns .i?�5�. �k�. ', , ly' �?i.;7''�, � '� Y �4! `��,;4 +S.r,1 �i.•
1
�.4rlrrr�lr )� � . � ,L t�l�,y rli },.. r lal' i ��y y3�L'•- R-
'!S j�r�t`r•�����ti` r`- Yr 1 L+'r' /,�/1�y '_�� �' �iit�!'P��1YAr. r�+ ��r '}s, .��'';.',- _ ''y��' t%(Jy�:;. '�
}i � '�' ��1% � ,i1 i� � '• r ., r ryr f iA., J �, ". r, Y r'sl ��~%G r vY 1';. L-`+r> ' / � 1 ��yf; �"�4 ' .•
,,k,�-.J1, l�4rsV s. , 'S 1 V�.'S rr' ''�e1� � "��'r .�f' ..� c+�• tf'+�:iisv,Fr• ;` '� r
t F i �. f +}. -, t �.1 _ � .���}';' � ySY �• r r7«1 L Y � � r - ' '�'C,l �• '1
C;�ti� s*eT , 5 �« ��V.' i'r {��! '� � � � Vr+'•' ' V r � �:�� rti r
��M � . Y..,--•��•1.ft� �*'�,'i�#+� �,wt,}'•�'re`t'��i:,�}'Y,'w: �"'� r�/��"�,�r, i f H4RRR"' i«�,j, .k,dit•�f �,, � l "i,"�
� �' ..�� .`��'��;r�'I.Fy::99��ljl 'r+:27��'' i �p �;,519'. ns.,.. � Y� ' "� t,Y�1t•:k ` f�.,':
� �i ,�;�'+ j'`��``rl;;s•,'Y",� !�u�� f �'V a �'q_';?' ''F� i? �/ •�' �" � rdiYly� r'` '�'y '�.r
yY W •r.. ;j•i f �S"(�''.'�� �+l1 r, � Y r:: 1
•� J`P�I"'r�.:3 '`�jiy �S`� � l � r+��' `^ r,' "gi ��'�y!� t r � N,. . ;e.
..` � `� .{F4.•�ti%ir��4+ .r� k`T� .y �i' f ,r. '�' M' r► r �y[� S''">` �.'�r

Po VD
-P +,.-�t•j '1, F 6 ' r r'� f C'Sk'•" s4- -
_ �A • • A1hltj r °S10N *0 �'•w q_ 3 E 21'-, f .r�,-L., '� ` i �- �. '
'1 k
Ij
' f*OrF Heighli' �ts�`v� •.y' - _ : •ti. .. '
a
1777 t"ig'T�.-z_
rKKL :,�i r � � lalo MILITARY RI=SERVA
�r-'Athinonl'• SANDY GROVE cN 1
177e
MWT
r . / P64NK Rt) LAKE
:McCain-
171�. ,•�. r� PLANK ARWY
/ 1714300
s i 171• Morllrose l,r a-< 1. >
A►(•101MZOM RO• �.1
1301 J,J Raeford
ry
Municipal Doc
,4 [F _ -.' _ . 711> :-::; •:. Airport a ..
�. t=f Po nll ♦' 7AWi 1i71r nn}, �"'�- a !J •F p'• ITnID tiaw :$
WnTROlt 1•.0 �1 Loll
yl, �S 1773rlWAAvfm c -
lA%[ j SIIVfA �II
Y 5 T
rC �rcLUABt7NVir
+ ..�C "AD. Silver o teAsiA'� J .
r it? _ 131+J Ci�l fAr I i0 IT `
Sevnd ,• �..* I19;� tilt 1
171 1 C �• v' i 'ti d - ys r ', At r 3 1 'N I .1 I ij\M17 119 J v r
e�OCC�' ' VSRY IT'1'A07
PAS
C �` .' r. , „ _ � - BB. 1717 : _ ��1'FL:RO - ' - • �� . .. ~ R}{i • ,' ` i
WE HIM � WFJ
►� _ 10
BUFfa LAK y f uc
r'r 7�y0ff r .1 $prl,- ` 'Ti 707i' .e1707 77 a ►Vd"�' RO•�.' 1.7 ! 1r 7 a
,`Aitl• C+37 ^1 tirl t r'xn f, ,,f:.� lk - •{1 •I IAI
+ q �0 1700 rA5'170]. v r. yHl��tS!1� r WAfL1IgR R6 +T ff 1►1 is
a0l .'. ✓ OAKD Lt GIN 10, t
-
r -3 _ 1• ',y' 1]OB•:,;[,. -: c-, - ,01� r ra Ir07 70 ti •RA
70{ ^. �IK 1707 0 ► ' lh e0 V faS/' I
'o \� tool 5 '
�Ili: Befhef +• eEt ,' r•' �' �:' � ,h Nr" 17as �; �-: _i.'S tla] .I la 1J _h.t y t ? a ''rnorrM I
-�CLMAIE it
'q�•- �^��_� I131 -'= P ltle .OTrtR RO •Irs) ^! ✓I.19'Tllp' ter.
^r� irAIN01 1139 'r Do*.
14Z II14 .D LI CIC[AD S,NA
1147 SEAT � r skT�► 1, ; .
1174 14l �o �Q .D N *pNSONOi.Y ia3�`. Y� i
jj t 1 .` rr R� '' 1 DRANAY l• - •f .
yf.� ',•• Rp _ rf 111'1 lali lae I
'� IRCT01t ' fy I Va3 ! NCILL t1A1fwELL r.l•ACM
J a
„kr4,',�:P;:};is 1] IAA � Ciir�r _ _ � ^ ,.447
' �rt�.%C'r4 '1T ,7 s t- • t+AtR _ � Cp 6 G, ;
1700 y c 1171 �`aQs `,17a II NOKt
�. h
I. I r" S .• . A J �`" IU' t . ra3a
7' LU[ AD 11]7 'a 1001 0 HCCOR4ICK
174
!x • l Edinbur h 1.343
134
l
' ...)\' •;; 1' a ..? 1 I ]o � 'a 1JlR1ryj
1170 - 4 ;1170 �v�i:r! N4 ., P CAUCILIN
II
AQ1 r.7 1101 ROeI�' R e,l]ON I 1103 i
•r'. ,,,'+ l t i - `q II]7 'D { 1134
r13A POSD bill y
Ilit
94 cm
Pvrcel \ N 7 9
a
l * 7e
r - - n } � l .,� ,i.' , 6 i � A _t • � I I C! .n �j 1 rr•. 4 .

?.4
Operat6r,.Roy Wood: Date; 09/02/9zi
-to near -'e S I.-d o t h e tliin own 1000.0 feet D
n c e
I stinc er" �7 e S t, t
1. STEADY - STATE. LIVE 'WEIGHT.
�X_
-:b
0 Abs
1: s, 6 w S - f at, r ow
's i b s
0-6�i 5 ­(,.f., 0 C-zz.: I
'
j sh I nq o n'l 1-5 S s,
770 :sows (s.'EL r r ci w to: -wean x 4'::":','l bis 3 4 10 1 b s
0 -head (wear, to feeder- ) y: 3o I b s I bs
DY AI TOTAL STEA ST 'E:----IVE WEIGHT, (SSL14) :::3� 4 10 1 b s
2. MINIMUM REQU I RED TREATMENT VOLU,j 017 LAGOON
Tre atme n t Volume(CF),/lb. SSLW
Y,0.1-ume- 33341v--lb-s.-
I b LWI CF/ I b. -SSLW -T.Ire.;itment V o­'_6"_0`( SS
V -urrie 3 f e'i:,_
�_-_P34 1_ b I
3. STORAGE VOLUME, FOW'SLUDGE-'AdMmuLATION,
VO I Lime .-.--().0 E u'b I c_ f e et
4. TOTAL DESIGN ''VOLUME
Iris Ids top. 0.6 feet Inside to l..q n 9 p w I dth 16.5.0 feet
9Z.Of feet
Top of d I kv ---at, e I evat i on.
F r c e b C, a,t.' 10 feat; Side s 1,64,e 1
.f :. Sj C? I (Inside lagoc,ri)
Total des ig 11 "1 91 .0 feet
0 01 f�eet
Seasonal.' h i q.h' , " "water tab . 10 P) R Y a t: I o n C) feet
Total des-l$n,:,vol6rKa!-usjnq prd smol da I fot-rnu I -a
SS/END1 'SS/ENDZ-,.S.S/SIDE,I="--,SS/SIDEZ LENGTH WIDTH DEPTH
11.0
0 0 4 0 159. 0
3 0
AREA CIF. - TOP
Lr;NGT-H W I DTH
t21 4
6 1 C) 5 6 0", (AREA
OF TOP)
AREA OF:-.L -`1TTqM,'.-
7' LENGTH'.'* W I DIH
sib:ciY G .0,
Z9574. 0 .(AREA
OF BOTTOM)
--AREA,r-IF"MIDSECTION
CENd WIDTH * 4
.
�_l 0
-176 904 0 iWEA
CIF. MIDSECTION
CU..,FT. -DSE TION)
REA'TOP- (4*AREA MI
+ 'AREA BOTTOM3
176904.01
29574.0
VOLUME'..OF"LAGOON AT- TQTAL'•DESIGN'LIQUID
LEVEL
* 4)
DEPTk
490479 CU, f

tZ
5.=TEMP,ORARY STORAGE RE�IUIRED _
4 DRA INAGE=
:Lagaat► tr,p af.,5�,d i Asa) y.
- Leii jth'-U-- * WI dt+ r4 r '
_
°390.0 #65:0",: 6450,0 ,guare fe't
13uI_Idings _(r.00fKan'd, Iot:wate
'square feet
:T_ OTAL.'DA-.-64050.0 square feet
De a i•�qn' ternporary_,Atbra a peg- l:��tl to be 1 no days.
-. EA. 'Vol.urn e -of=was.t.e.-produced
Ap�p�ru.:-i-rna�e:"da,i=Iy;= r•a�iic't 1, n ctf rnanur@. ,i n .GF/Li3 SSLW O.L�tj1" ,.
-Vulurne _, 33341,0 ;Lbs.` SSLW: * CF of waste/Lki./Day
V6I:urna._ ..."':'-_8#.421''.Cei '(`c feet'
SLR,: Va I Urne of wash water•- - ..
Th.i;a i,s '.tha'-Jvnou-nt of fresh water us@d-;far wash+f ng f I uar s� or v _
i;
of`' :frea.h .watQ.r'used_sfpr, a Cl us system: Flush systems that rec
i
- the.":I.a�aar� wader ara! acc.r�unted'. for f n' SA.
Volume O.OF.9ai Ion,S/day.`
_ 180 days stara3e/7:45
3;
VOA ume-.'0:0' eL.ib,I c_ feet' .
5C. Vo I urne af= ra i nfa l !` i, n e'xc ess of evapurat..! a.n
Gse `parlod ofKtlma-.When�Y•alnfai i e};ce@+s @V,ap17r•a,iri by 'largest
;
4.
1$0 days 'exess ra'i nfa I !, 7.0: 1 r,ches
VUlerne 7 4�Anr �,nA /=,1Z Inched per .fvot
Volume = 37537.3 c ub i c: f e
.t

-71 �. -� .. �•. - jj''
i
5D. :Vo I urne f 25 year. 24,`hour star rn :
Vu I urns jl% d 4�1 ruches'/ !2 i r,c.hes, per fc�t DA
` volume' 5392Scub I feet•
rr,'#,fY {t�''� k�•�_z.7�,'piy` .b .r -.7.
xV
TOTAL REQUI ED �TEM,Q;Ry�ARY,. STOFr'A4E
SA :w� "� ��! a;' S 142 I', .cub 1 c�s e t
5B.' ''}}'f='`,U- 0` cut+ i c 4'eet•
5C'.1`+ 'f e'e t' `
'.5D.r3593'cub l'c feet ,
TOTAL ' •154351 cub I c feet
4 . SUMMARY
T6ta1-r.equIr•ed"w0lume 4S77c5l1:c.uV!c.' feet I
Tot'aI 'dgsI n yvoIurne. �aval 14; r ,�70�7'7�Gub1c .Feat i
llI , '.v f ', , I
'w r7
Mtn req. tr-aatrnent•valurne"�;lLis ;SIudge'Ucc^6tQuIa,t1l:+r, .:��41Q cutlic
At a I ev.' ty86.'6 fleet ; Vu I urns i's' Z24424 cub I c f eat ( and purnp I r,3.
Tota I des 1'sr, va I ume Al 0tS 25yr-21-4hr,: storm -I s ;' 455087 cut, 1 e feet
. , ', 1;xa; -,' ter`".' - •'-c I
At elev. 90.3-,feet i'Valume ls• • +,44S534'c'ubIc feet (start pump.i:
Seasonal h19 water, tab .Ie7eIevatIon 30.0 f t
7. ; • DESIGNED BY :: APPROVED BY: -
DATE:. 9/ r� DATE:
NOTE: SEE ATTACHED. WASTE UTILIZATION• PLAN . �
• y I
it ,. •+' .. '

Beverly Eaves Perdue
Governor
NCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Coleen H. Sullins I R EC' E �► r" I
Roy W Wood
R&R Pork Farm
540 Burning Tree Rd
Pinehurst, NC 283749335
Director
July 31, 2009
Subject: Application for Renewal of Coverage for Expiring State General Permit
Dear Permittee:
Dee Freeman
i Secretary
i
0ENR-FAYEfTEtllfl-E RF1310 Al tErlr; i
AUG 0 5 29
This is a follow-up to our March 3, 2009 letter requesting an application from your facility for the continued coverage under one of the
Animal Waste Operation State Non -Discharge General Permits. Current General Permits expire on September 30.2009. Copies of the
new General Permits are available at hgp://h2o.enr.state.ne.uslaps/afou/applications.htm or by writing or calling:
NCDENR — DWQ Animal Feeding Operations Unit
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure your continued coverage under the State Non -Discharge General Permitsyou must submit an application for permit
coverage to the Division. Enclosed you will find a `Request for Certificate of Coverage Facility Currently Covered banExpiring
State Non -Discharge General Permit.' The application form must be completed and returned by September 3.2009. Please note, you
must include two 2 copies of your most recent Waste Utilization Plan with the apiplication form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the State Non -Discharge General Permits, the enclosed application, or any related matter please feel
free to contact the Animal Feeding Operations Unit staff at 919-733-3221.
Sincerely,
Ted L. Bush, Jr., Chief
Aquifer Protection Section
Enclosures
cc (w/o enclosures): Hoke County Soil and Water Conservation District
Fayetteville Regional Office, Aquifer Protection Section
AFO Unit Central Files-/470031
Ernest Smith Farms Inc
AQUIFER PROTECTION SECTION
1636 Mail Service Center. Raleigh, North Carolina 27699-1636 One
Location: 2728 Capital Boulevard, Raleigh, North Carolina 27604 N ot-th Caro l i n a
Phone: [phone] FAX 1: 919.715-0588; FAX 2: 919.715-60481 Customer Service: 1-877-623-6748 �]ttor�N�!`J/
Internet: www.ncwateMualiy.org Naturally
An Equal Opportunity s Affirmative Action Empioyer

Roy & Richard Wood
R&R Pork Farm
4051 Aberdeen Road
Raeford NC 28376
Dear Roy & Richard Wood:
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P. E., Director
Division of Water Quality
October 1, 2004 RECEIVED
OCT 15 2004
OENR - FAyETTEMLLE REGIONAL OFRCE
Subject: Certificate of Coverage No. AWS470031
R&R Pork Farm
Swine Waste Collection, Treatment,
Storage and Application System
Hoke County
On .tune 11, 2004, the North Carolina Division of Water Quality (Division) issued a revised State General
Permit for swine facilities. The General Permit was issued in accordance with the directive of Senate Bill
733 (Session Law 2003-28).
In accordance with your application received on March 3, 2003 and in accordance with the directive of
Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to Roy &
Richard Wood, authorizing the operation of the subject animal waste collection, treatment, storage and
land application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AWS470031 which expires October 1, 2004.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the R&k Pork Farm, located in Hoke County, with an animal capacity of no greater
than an annual average of 770 Farrow to Wean swine and the application to land as specified in the
facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or Farrow to
Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary, they may
be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a rate of 4
gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Since this is a revised State
General Permit, it contains new requirements in addition to most of the conditions contained in the
previous State General Permit. Enclosed for your convenience is a package containing the new and
revised forms used for record keeping and reporting. Please pay careful attention to the record_ keeping
and monitoring conditions in this permit.
Aquifer Protection Section -- Animal Feeding Operations Unit one
1636 Mail Service Center, Raleigh, North Carolina 27699-1638 NorthCarolina
Phone: [phone] FAX: [phone] Internet: h2o,enr.state.nc.us ;Vatumlly
An Equal Opportunity/Affirmative Action Employer— 50% Recycled110% Post Consumer Paper

If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 2H .0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per MRCS standards a 100 foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If. you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Duane Leith at [phone].
Sincerely,
v
for Alan W. Klimck, P.E.
Enclosures (General Permit AWG 100000)
cc: (Certificate of Coverage only for all cc's)
Fayetteville Regional Office, Aquifer Protection Section
Hoke County Health Department
Hoke County Soil and Water Conservation District
Permit File AWS470031
APS Central Files