260007_CORRESPONDENCE_20171231

NORTH CAROLINA
Department of Environmental dual

Ray Bullard
Bullard Farm
2224 Stedman Cedar Creek Rd.
Stedman NC 28391
Dear Ray Bullard:
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P. E., Director
Division of Water Quality
October 1, 2004
OCT 15 zoos
DENR - FAYETTEM LLE REGIONAL 4FIRCE
Subject: Certificate of Coverage No. AWS260007
Bullard Farm
Swine Waste Collection, Treatment,
Storage and Application System
Cumberland County
On June 11, 2004, the North Carolina Division of Water Quality (Division) issued a revised State General
Permit for swine facilities. The General Permit was issued in accordance with the directive of Senate Bill
733 (Session Law 2003-28).
In accordance with your application received on January 27, 2003 and in accordance with the directive of
Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to Ray
Bullard, authorizing the operation of the subject animal waste collection, treatment, storage and land
application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AWS260007 which expires October 1, 2004.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Bullard Farm, located in Cumberland County, with an animal capacity of no
greater than an annual average of 1574 Feeder to Finish swine and the application to land as specified in
the facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or
Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary,
they may be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a
rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC.- An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either Wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Since this is a revised State
General Permit, it contains new requirements in addition to most of the conditions contained in the
previous State General Permit. Enclosed for your convenience is a package containing the new and
revised forms used for record keeping and reporting. Please pay careful attention to the record keeping
and monitoring conditions in this permit.
Aquifer Protection Section —Animal Feeding Operations Unit
1636 Mail Service Center, Raleigh, North Carolina 27699-1638 One
NorthCarona
Phone: [phone] FAX: [phone] Internet: h2o,enr.state,nc.us �at�ra���
An Equal OpportunitylAffirmative Action Employer — 50% Recycledl10% Post Consumer Paper

If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 2H .0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100 foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Duane Leith at [phone].
Sincerely,
v
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
Fayetteville Regional Office, Aquifer Protection Section
Cumberland County Health Department
Cumberland County Soil and Water Conservation District
Permit File AWS260007
APS Central Files

a
Nutrient Management Plan For Animal W
04-12-2006.
This plan has been prepared for:
Bullard Hog Farm
Ray Bullard
2224 Stedman Cedar Creek
Road
Stedman, NC 28391
[phone]
This plan has
.
APR 0 6 2=
Greer Moore
Clear Run Farms Consulting Services
PO Box 338
Harrells, NC 28444
[phone]
Z.ZvAgm
Developer Signature
Type of Plan: Nitrogen Only with Manure Only
Owner/Manager/Producer Agreement
I (we) understand and agree to the specifications and the operation and maintenance
procedures established in this nutrient management plan which includes an animal
waste utilization plan for the farm named above. I have read and understand the
Required Specifications concerning animal waste management that are included with
this plan.
r
R f
i
gnature (owner)
Signature (manager or producer)
1,2- -(-7) (,:,
Date
Date
This plan meets the minimum standards and specifications of the U.S. Department of
Agriculture - Natural Resources Conservation Service or the standard of practices
adopted by the Soil and Water Conservation Commission.
Plan Approved By: 9/-/Z —GG
Technical Specialist Signature Date
386904
Database Version 3.1 Date Printed: 04-12-2006 Cover Page 1
Nun

Nutrients applied in accordance with this plan will be supplied from the
following source(s):
Commercial Fertilizer is not included in this plan.
S7
Swine Feeder -Finish Lagoon Liquid waste generated 1,459,098 gals/year
by a 1,574 animal Swine Finishing Lagoon Liquid operation. This
roduction facili has waste store a capacities of approximately 180 days.
Estimated Pounds of Plant Available Nitrogen Generated per Year
Broadcast
3361
Incorporated
5772
Injected
6356
Irrigated
3653
Actual PAN Applied
(Pounds)
Actual Volume Applied
(Gallons)
Volume Surplus/Deficit
(Gallons)
Year 1
79104.70
2,837,909
-1,378,811
Year 2
7,899.20
33155,264
-1,696,166
Note:._ 1n source ID. S means standard source, t3 means use_...---_--.--_.....--..._.._.._�_�
r defined source.
635713 Database Version 3.1 Date Printed: 06-19-2007 Source Page 1 of

,J Narrative
Mr. Bullard is allowed 30 lbs. of PAN on his winter cover crops that he plans to turn under. The 30 lbs.
of PAN will then be deducted from the following crop PAN rate.
635713 Database Version 3.1 Date Printed: 06-19 2007 Narrative Page 1 of 1

The Waste Utilization table shown below summarizes the waste utilization plan for this operation. This plan provides an estimate of the number of acre,''=
cropland needed to use the nutrients being produced. The plan requires consideration of the realistic yields ofthe crops to be grown, their nutrient requim �
and proper timing of appl ications to maximize nutrient uptake.
This table provides an estimate of the amount of nitrogen required by the crop being grown and an estimate of the nitrogen amount being supplied by manure
other by-products, commercial fertilizer and residual from previous crops. An estimate of the quantity of solid and liquid waste that will be applied on each field
order to supply the indicated quantity of nitrogen from each source is also included. A balance of the total manure produced and the total manure applied is
included in the table to ensure that the plan adequately provides for the utilization of the manure generated by the operation.
Wade Iltiliysgtinn Tnhle Vipur 1
Tract
Field
Souree
ID
SOB Series
TOW
Acres
Use.
Acres
Crop
RYE
Apphc,
Period
Nitrogen
PA
Nutrient
Reg7d
(1bs/A)
Cantu
Felt
Nuuiem
Applied
RSA)
Res..
Obs/A)
Apphc
Method
Manure
PA
Nutrient
Applied
OVA)
Liquid
Mzmm&
pplied
(acre)
Solid
Manure
Applied
(acre)
Liquid
Mantua
Applied
(Field)
Solid
Manure
Applied
(Field)
N
N
N
N
1000
gWA
Tons
1000 gals
tons
3299
IA
S7
4.40
4.40
Small Grain Overseed
l.D Tons
l0/t-3/31
50
D
0
]trig
5
19.9
0.00
97.88
0.0E
3299
IA
S7
utters
4.40
4.40
Hybrid Barnudagass flay
5.5 Tons
3/1-9130
*275
0
0
Irrig.
275
109.85
0.00
483.32
0.0E
3299
113
S7
Butters
6.40
6.40
Small Grain Ovenced
1.0 Tons
10113/31
50
0
0
Irrig.
5
19.97
0.04127.82
0.01
3299
IB
S7
IButters
6.40
6.40
Hybrid Bermudagrass Hay
5.5 Tons
3/1-9130
•275
0
0
Irrig,
27
109.85
0.00
703.02
0.01
3299
3A
S7
Istallings
2.40
2.40
Corn, Grain
110 bu.
2115-6130
* 138
0
20
brig
118
47.13
0.00
113.12
0.0E
3299
3A
S7
Stallings
2.40
2.40
Wheat, Grain
50 bu.
9114/30
"120
0
0
Inds.
48
19.1
0.
46.02
0.01
3299
7A
S7
Stallings
4.60
4.60
Corn, Grain
110 bu.
2115-6130
* 138
0
20
brig.
118
47.13
0.
216.92
0.01
3299
7A
S7
Stallings
4.60
4.60
Wheat, Grain
50 bu.
9/1-4/30
*120
0
0
brig.
48
19.17
0.
88.20
0.01
3299
9A
S7
utters
3.40
3.40
Cony Grain
100 bu.
2115-WO
*125
0
20
irrig.
10
41.94
0.
142.60
0.01
3299
9A
S7
utters
3.40
3.40
Wbeat, Grain
50 bu.
9/1r4/30
*120
0
0
brig.
48
19.1
0.00
65.19
0.01
3299
9B
97
IBM=
4.50
4.50
Corn, Grain
100 bu.
2/15-/30
* 125
0
20
brig.
105
41.94
0.00
188.74
0.01
3299
913
S7
Butters
4.50
4.50
Whea4 Grain
50 bu.
9/1-4130
*120
0
0
Inig,
48
19A7
0.00
86.28
O.Ot
32"
9C
S7
Butters
4.50
4.50
Corn, Grain
100 bu.
2/15-6/30
*125
0
20
Irrig.
105
41.94
0.
198.74
0.01
3299
9C
S7
Butters
4.50
4.50
Wheat, Grain
50 bu_
9/1-4/30
*120
0
0
irrig.
48
19.17
0.
96.28
0,0E
3299
9D
S7
3.50
3.50
Corn, Grain
100 bu.
2/15{130
*125
0
20
brig
105
41.94
0.
146.
of
3299
9D
S7
utters
3.50
3.50
Wheat, Grain
50 bu.
9/1-4/30
'*120
0
0
brig.
4
19.17
0.
67.1 l
0.01
635713 Database Version 3.1 Date Printed: 6/19/2007 WUT Page 1 of 3

Waste Utilbation Table
'' Year 1
Tract
Field
Source
ID
Soil Series
Total
Acres
Use.
Acres
Crop
RYE-
Applic.
Period
invn
PA
Nutrient
Req'd
(Ibs/A)
Gomm
Felt.
Nutrient
Applied
(lbalA)
Res.
(lbslA)
AppEc.
Metbd
Manure
PA
Nutrient
Applied
(ibs/A)
Liquid
ManurcA
pphad
(acre)
Mid
Manure
Applied
(am)
Liquid
Manure
Applied
(Field)
(Fie
N
N
N
N
loop
gd/A
Tons
1000 gals
tons
Total Applied,
I000 gallons
2,837,91
Total Produced, 1000 gallons
1.459.1
Balance, 1000 gallons
-1�378.81
Total Applied, tons
0.09
Total Produced, tons
0.04
Balance, tons
0.01
Notes: 1. In the tract column, — symbol means leased, otherwise, owned. 2. Symbol * means user entered data.
635713 Database Version 3.1 Date Printed: 6/19/2007 WUT Page 2 of 3

Waste Utilion Table -Vpnr 2 }� zsr_
Tract
Field
Source
ID
Soil Series
TOMI
Acres
Use.
Acres
Crop
RYE
Applic
Period
Nitrogen
PA
Nutrient
Rod
(lbs/A)
Ccma
Fert.
Nutrient
Applied
(lbs/A)
Res.
(lbs/A)
Applic.
Method
Manure
PA
Nutrient
Applied
Obs/A)
Liquid
ManureA
ppked
(arse)
Solid
Manure
Applied
(arse)
Liquid
Manure
Applied
(Field)
gt
MaN
Appli
(Field)
N
N
N
N
I000
gal/A
Tons
1000 gals
tons
3299
IA
S7
utters
4.40
4.40
Small Grain Ovcrseed
1.0 Tons
10/1-3/31
50
0
0
Irri&
5
19.97
0.
87.88
0.01
3299
1A
S7
Butters
4,40
4.40
Hybrid Bennudagrass Hay
5.5 Tons
3/I 9/30
*275
0
0
brig.
27
109.8
0.
493.32
0.01
3299
1 B
S7
Buttm
6.40
6.40
Small Grain Overseed
1.0 Tons
10/1-3/31
50
0
0
brig.
5
19.
0.
127.
0.04
3299
IB
S7
utters
6.40
6.40
Hybrid Bermudagmss Hay
5.5 Tans
3/1-9/30
*275
0
0
Urig.
27
109.85
0.
703.02
0.01
3299
3A
S7
tailings
2.40
2.40
Wheat, Gratin
50 bu.
9/1-4/30
*120
0
0
Irrig
29.7
0.
69.02
0.01
3299
3A
S7
tailings
2.40
2.40
Soybeans, Manured, Double Crop
32 bu.
4/1-9/15
* 128
0
1 0
brig.
12
51.13
0.
122.71
0.01
3299
7A
S7
Istauinp
4.60
4.60
Wheat, Grain
50 bu.
911-4/30
* 120
0
0
brig.
28.7
0.
132.29
0.01
3299
7A
S7
6inp
4.60
4.60
Soybeans, Manned, Double Crop
32 bu.
4/1-9/15
*129
0
0
brig.
128
51.13
0.
235.1
0.01
3299
9A
S7
Bud=
3.40
3.40
Wheat, Grain
50 bu.
9114/30
* l20
0
0
Irrig.
72
28.7
0.
97.78
0.01
3299
9A
S7
Butters
3.40
3.40
Soybeans, Manwed, Double Crop
29 bu.
4/1-9/15
*116
0
0
brig.
116
46.34
0.
157.54
0.04
3299
9B
S7
Buttets
4.50
4.50
Wheat. Grain
50 bu.
9114/30
*120
0
0
Irrig,
72
29.76
0.00
129.42
UN
3299
9B
S7
IButters
4.50
4.50
Soybeans, Manurcd, Doublc Crop
29 bu.
4/1-9/15
*116
0
0
brig.
116
46.34
0.00
208.51
0.01
3299
9C
S7
Butters
4.50
4.50
Wheat, Grain
50 bu.
9/1-4/30
*120
0
0
Irrig
28.76
0.00
129.42
0,01
3299
9C
S7
Buftm
4.50
4.50
Soybeans, Manmcd, Double Crop
29 bu.
4/19/15
* 116
0
0
brig.
116
46.3
0.
208.51
0.01
3299
9D
S7
Butters
3.50
3.5
Wheat, Grain
SO bu
9/1-4/30
* 120
0
0
brig
28.7
0,
100.660.01
3299
9D
S7
utters
3.50
3.50
Soybeans, Mmumd, Double Crop
29 bu.
411-9/15
0116
0
0
Irrig.
116
46.34
0.
162.17
0.01
Total Applied,
1000 gallons
3,155.2
Total Produced, 1000 gallons
1,459.1
Balance, 1000 gallons
-1,696. L
Total Applied, tons
0.01
Total Produced, tons
0.01
Balance, tons
0'FN
Notes: 1. In the tract column, - symbol means leased, otherwise, owned 2. Symbol' means user entered data.
635713 Database Version 3.1 Date Printed: 6/19/2007
WUT Page 3 of 3

„-'f'he table shown below provides a summary ofthe crops or rotations included in this plan for each Meld, Realistic
Yield estimates are also provided for each crop in the plan. In addition, the Leaching Index for each field is shown,
where available.
Planned Craps Summary
Tract
Field
Total
Acres
Useable
Acres
Leaching
Index (M)
Soil Series
Crap Sequence
RYE
3299
1 A
4.40
4.40
N/A
Butters
Small Grain Overseed
1.0 Tons
Hybrid Bermudegress Hay
5.5 Tons
3299
1 B
6.40
6.40
NIA
Butters
Small Grain Overseed
1.0 Tons
Hybrid Bermudagmss Hay
5.5 Tons
3299
3A
2.40
2.40
N/A
Stallings
Cam, Grain
110 bu.
Wheat, Grain
50 bu.
Soybeans, Manured, Double Crop
32 bu.
3299
7A
4.60
4,60
N/A
Stall'
Corn, Grain .
110 bu.
Wheat, Grain
50 bu.
Soybeans, Manured, Double Cru
32 bu.
3299
9A
3.40
3.40
N/A
Butters
Corn, Grain
100 bu.
Wheat, Grain
50 bu.
Soybeans, Manured, Double Crop
29 bu.
3299
9B
4.50
4.50
N/A
Butters
Corn, Grain
100 bu.
Wheat, Grain
50 bu.
Soybeans, Manured, Double Crop
29 bu.
3299
9C
4.50
4.50
N/A
Butters
Corn, Grain
100 bu.
Wheat, Grain
50 bu.
Soybeans, Manured, Double Crop
29 bu.
3299
9D
3.50
3.50
N/A
Butters
Com, Grain
100 bu.
Wheat, Grain
50 bu.
Soybeans, Manured, Double Crop
29 bu.
PLAN TOTALS: 33.70 33.70
LI
Potential Leaching
7ecluaical Guidance
< 2
Low potential to contribute to soluble
Notre
nutrient leaching below the root zone.
>= 2 &Moderate
potential to contribute to
Nutrient Management (590) should be planned.
<= 10
soluble nutrient leaching below the root
zone.
High potential to contribute to soluble
Nutrient Management(590) should be planned. Other conservation practices that
F>
nutrient leaching below the root zone.
improve the soils available water holding capacity and improve nutrient use efficiency
10
should be considered. Examples are Cover Crops (340) to scavenge nutrients, Sod -Based
Rotations (328), Long -Term No -Tilt (778), and edgo-of-field practices such as Filter
Strips (393) and Riparian Forest Buffers (39I ).
1C7 r•7111 nat.ho— V.—;i ” 9 1 nQ*o P int o 4n onnn9

`Ihe Irrigation Application Factors for each field in this plan are shown in the following table. Infiltration rate varies
with soils. If applying waste nutrients through an irrigation system, you must apply at a rate that will not result in
runoff. This table provides the maximum application rate per hour that may be applied to each field selected io
receive wastewater. it also lists the maximum application amount that each field may receive in any one application
event.
Irrigation Application Factors
Tract
Field
Soil Series
Application Rate
(inches/hour)
Application Amount
(inches)
3299
1 A
Butters
0.50
1.0
3299
IB
Butters
0.50
1.0
3299
3A
Stallings
0.50
1.0
3299
7A
Stallings
0.50
1.0
3299
9A
Butters
0.50
1.0
3299
9B
Butters
0.50
1.0
3299
9C
Butters
0.50
1.0
3299
9D
Butters
0.50
1.0
G ry C-7 1 1 rl....1....... 7 1 C -*- n_:-+-A 411 n nnn•r 1 AV It.,.... I' -C 1

- The following Lagoon Sludge Nitrogen Utilization table provides an estimate of the number of acres needed for
sludge utilization for the indicated accumulation period. These estimates are based on average nitrogen
concentrations for each source, the number of animals in the facility and the plant available nitrogen application
rates shown in the second column.
Lagoon sludge contains nutrients and organic matter remaining after treatmentand application of the effluent. At
clean out, this material must be utilized for crop production and applied at agronomic rates. In most cases, the
priority nutrient is nitrogen but other nutrients including phosphorous, copper and zinc can also be limiting. Since
nutrient levels are generally very high, application of sludge must be carefully applied.
Sites must first be evaluated for their suitability for sludge application. Ideally, effluent spray fields should not be
used for sludge application. if this is not possible, care should be taken not to load effluent application fields with
high amounts of copper and zinc so that additional effluent cannot be applied. On sites vulnerable to surface water
moving to streams and lakes, phosphorous is a concern. Soils containing very high phosphorous levels may also
be a concern.
Lagoon Sludge Nitrogen Utilization Table
Crop
Maximum
PA-N hate
Ib/ac
Maximum Sludge
Application Rate
1000 gal/ac
Minimum Acres
5 Years Accumulation
Minimum Acres
10 Years Accumulation
Minimum Acres
15 Years Accumulation
Swine Feeder -Finish. Lagoon Sludge - Standard
^.om 120 bu
150
13.16
19.73
39.46
59.20
clay 6 ton R.Y.E.
300
26.32
9.87
19.73
29.60
Soybean 40 bu
160
14.04
18.50
37.00
55.50
635713 _.^. Database Version3.1 DatePrinted: 06-19-2007 Sludge Page 1 of 1

The Available Waste Storage Capacity table provides an estimate ofthe number of days of storage
capacity available at the end of each month of the plan. Available storage capacity is calculated as the
design storage capacity in days minus the number of days of net storage volume accumulated. The start
date is a value entered by the user and is defined as the date prior to applying nutrients to the first crop in
the plan at which storage volume in the lagoon or holding pond is equal to zero.
Available storage capacity should be greater than or equal to zero and less than or equal to the design
storage capacity of the facility. If the available storage capacity is greater than the design storage
capacity, this indicates that the plan calls for the application of nutrients that have not yet accumulated.
If available storage capacity is negative, the estimated volume of accumulated waste exceeds the design
storage volume of the structure. Either of these situations indicates that the planned application interval
in the waste utilization plan is inconsistent with the structure's temporary storage capacity.
Available Waste gtnrave Canacitv
Source Name
Swine Feeder -Finish Lagoon Liquid
Design Storage Capacity (Days)
Start Date
911
180
Plan Year
Month
Available Storage Capacity (Days)
1
1
60
1
2
93
1
3
152
1
4
180
1
5
180
1
6
180
7
180
I
8
179
1
9
180
1
10
180
1
I
180
1
12
180
2
1
180
2
2
180
2
3
180
2
4
180
2
5
l80
2
6
180
2
7
180
2
8
180
2
9
180
2
10
160
2
11
141
2
12
115
* Available Storage Capacity is calculated as of the end of each month.
— ----- _._,-._._.__.___.__
635713 Database Version 3.1 Date Printed: 06-19-2007 Capacity Page 1 of 1

�ANIMAL WASTE UTILIZATION PLAN
ti
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm:
Owner/Manager Agreement
T_ (we) understand and will follow and implement the specifica4_cns
and the aperat_cn and maintenance procedures established in the
approvedanimal waste O..-- l.- i'. plan for the fa=M'naMed GbCV_
(-ire) know that any expansion to the exisc_nc design capacity cf :he
waste treatment and storage system Cr ccnstr'ucKcn of nOw
facilities will require a new cerzifica=icn to be su_^mi =ed == the
NCrth Carolina Division of Water Quality (NCD'WQ) before the new
animals are stocked. ' (we) also understand that _the a „+ust a nc
discharge of anima_ waste from this system to surface waters of Ce
state from a szcrm even: less severe than the 25-year, 24--cur
s__rm. The approved ;._an will he file- cm -size at the farm ct= =e
and at ,.he office of Ve local SC_- and rioter Ccnse&:a=0 0:=.:
and will he available Or =e'r_ew by NCDWQ unn req eG_.
Name of Facility owner: Ray 3ullard
0 ease p__st)
Signature . Bate; -
Name of Mar_ager(V different from owner)
Signature:
Late:
Name of Person Preparing Plan: (?tease psint)La= y E Simpson
Affiliation:Cumberland SWCD Phone No. [phone]
Address (Agency): 121 East Mountain Drive Ste 229
Fayetteville NC 28306-3422
Signature: e`J Date:
Page: 12

"� i�"'�i;sir ���� ^ 1�}}�y'"�'. ,�"•-_..fj7�:}Y7'4:i�'s<c t
! � ++ rJ�. + F('�� Firff '' ��+.qM w. �"C"��''1`• ��F � F i' N�.l. �i`
aJZe• T �r L..� r a,�t ~.f�a. r :"y'S s�'as{a+k} 7' Y T' �� i- it
f+
� � !° ,nw � t ,ry'yt," Hr ;� �"'e.« r'� •y4at .r l:
rJ�* ''�y�/"��{��'��E�*.'s'"'.wi ,.w� y^�'P-a a�e+�,f.�;Yy,t'�iL-'_ �^J•C � ,.t'". Y
`�
i i t'yl'f !i"p r;'+ ! Y+~� •'"�!. �w si ;?131,4 .,� ;-''.Ml,".
.� L '�.� � t? li ,a r � T. 4�hr:�17'•r ��_�.d
f ��V1 iyF' Y. .(tom . �%t�'• � w?y'.'.if i'Ei j�,, i5w..
k! v w
a� rrr ti o?`Y',"^
t�4���;i� C,jXw � �fr P{,W�. R � ;.?he�p•� �„ 1 ?� �fa�r:�.,1...�,�1C�4 �tt
iPe' j.. Sir ,iy� �+ �: � Y F y�.4 ♦ �, r"�, `r yA �
a♦� a +
1hpi4e44 � �' `e.?•T}"r lY.tiF'� yf:'L�: ` �• i"k"��", m,,� j
'{{c. �' r� * •'fie ;�r� r�� `�;����5+"..�;?s•. , �.:
r i � ,..ITS 1' `` ,•�i.: �,.} �, r4.
'� st �`-�t „ri •`r' k.�,.r `° C�� ,'',1 i �r, y'nJ•� i u ~�' n 'k :'..
+yam a >+ '� � tr ' f �� t; � � � ��-,'�l•�r�,� y�� rr'r •�
Al.
Y
! .y
h'
yy R'
7 r
44 A. .r � �•
4i;A� ���,;; r» �'F « ,� *.. s, >s ��'� s'. ... ` i • -fit
�,�t s � .,:�. •tr ��'°Rp p' f t ..�tt '?...� f- i •� a nJ � �'�€ i� in iN. Tea .{,. - �, t� c. a.. �.
n:tj��K 4 r r �.�� E �� '`ir rY�+ � •:(6 t r . , �+s,� ! { s� iai, e«+�iX� �r% ,tL ti. ,�%.di �, 4� . i" 3 �"t� S i
�i - a.`�{�•'�i' � t .». " r' '�..- � 6�..++^ 1.4Y ne' 9... � s-"i-a W 4 ' t7 '�
Yi'�-� � kji'L` r �.s �l,.,� r, ..d s �•l"' x! t J �,, -t. _ ,M r-; r.., . �.
». hu r a 1 s :�S 1 t. {• tf T llr.r�w
fJ1ns I�`ly�'•�' 0"*1 .,r , f�-� it i , e?-! f s ,Srt,t �a i't r hew.
tr^.; ire ,o-`i-a~��iJ n�" ;•�a`y �^�'ua.d Alrt i� �'� i i` ` `'� �' -n ` r .q'r� •r��' 3:`
•SC - + fl e.Ew:.}a>-... r 1 r. .,� ,r' t 1 ' r y,{ E tr Y
a� +, •.�r _. �ler ah, rFi r a 7 t� q "a'� "Sri" < s r+ 1 '°
tX i ��.' •�,'. s r' ° r r'i ., . ' s 3H t' r�E� xr i��Y ,6 �+�ti"�u;�:','u�., h [ A ! i t �q_j +. y-' � r i , grti ,�� j..�
rt»rq c.. U.i: r:i`M . °A 4::«r4. r., .�a i R.' a .� 7: r hr »».,.a:::1. r.ra.,.l • A�! .aY �.F :�, �1i�;�r,��Yw.j.. •�' 4 .t +.. ` ! J.i.�'+. r'�'?' «

M;
NoUd2_10'
Date Received Complaint: October 21, 1996
Complaintant's Name: Mr. Ambrose Apkinson
Address & Phone No.: telephone [phone]
Stedman ?
Type of Complaint: Mr. Apkinson has a complaint about drainage from the Ray Bullard
hog farm off highway 210 South. According to Mr. Apkinson, water from the spray
field seeps through the soil and emerges in a large ditch immediately behind his
house, causing unbearable odors. He said there is no surface runoff, and wants
someone to come look at the situation.
Location of Complaint/County: At Mr. Apkinson's house off Highway 210. Turn left off
the highway down a two rut road between two bean fields, approximately one quarter
mile north of the Stedman -Cedar Creek cross road. Mr. Apkinson's trailer is several
hundred yards down this trail.
Date of Investigation: 10-22-96
Investigator: Ken Averitte and Ed Buchan
Samples'Taken: Yes: No: x
Narrative of Investigation Actions and/or Recommendations:
Visited with Mr. Apkinson the afternoon of 10-22-96 at his home. A large canal is
located immediately behind his mobile home, dug years ago for the purpose of drying
the area for farming purposes. A large water control structure is in east "end" of
the canal near his trailer. Mr. Apkinson believes that animal waste sprayed onto the
field seeps into the ditch and is causing unbearable odors to emanate from the
ditch. He wants the water level dropped to periodically flush the foul water and
thereby control odors. Although the water had a substantial algal growth, numerous
minnows were observed in the canal, and no overwhelming odors were noted at the time
of the visit. When asked, Mr. Apkninson conceded that the animal waste did not flow
into the lagoon overland. There are reportedly some drain tiles under this field. He
took the FRO number and agreed to call at any time the field tiles were discharging
wastes or when waste was noted running off the field.
Beavers have also contributed to Mr. Apkinson's frustrations by blocking the
aluminum water control structure, raising -the water level even higher than the
flashboards.
No further action appears warranted at this time. Mr. Apkinson has names and
numbers to call and will likely do so when he has something of substance.
Other Sections Involved:

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
Kerr T. Stevens, Director
August 10, 1999
Bullard Farm
Rt 2 Box 290-A2
Stedman NC 28391
Attn: Ray Bullard
,Tk?O W'A
IT
CDENR
NORTH CAROLINA DEPAR-rMENT OF
NVIRONMENT AND NATURAL RESOURCES
Subject: Certificate of Coverage No. AWS260007
Bullard Farm
Swine Waste Collection, Treatment,
Storage and Application System
Cumberland County
Dear Ray Bullard:
In accordance with your application received on May 25, 1999, we are forwarding this Certificate of
Coverage (COC) issued to Ray Bullard, authorizing the operation of the subject animal waste collection,
treatment, storage and land application system in accordance with General Permit AWG100000. This
approval shall consist of the operation of this system including, but not limited to, the management of
animal waste from the Bullard Farm, located in Cumberland County, with an animal capacity of no
greater than 150 Farrow to Finish and the application to land as specified in the Certified Animal Waste
Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This request
shall be made within 30 days of notification by the Division.
1617 Mail Service Center, Raleigh, NC 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Certificate of Coverage AWS260007
Bullard Farm
Page 2
This COC is not automatically transferable. A name/ownership change application must be submitted to
the DWQ prior to a name change or change in ownership.•
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual non -discharge permit by contacting the engineer listed below for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
The subject farm is located in the Fayetteville Regional Office. The Regional Office Water Quality Staff
may be reached at [phone]. If you need additional information concerning this COC or the
General Permit, please contact Dianne Thomas at [phone] ext. 364.
Sincerely,
j
P
T Kerr T. Stevens
cc: (Certificate of Coverage only for all cc's)
Cumberland County Health Department
Fayetteville Regional Office, Water Quality Section
Cumberland County Soil and Water Conservation District
Permit File
NDPU Files

war u sive
State of North Carolina kir, A
Department of Environment and Natural Resources j,� y 5
Division of Water Quality 1999
Non -{THIS FORM DAY BE PHOTOCOPIED e Pennit Application
OR USE 0 AN ORIGINAL)
Non-��SCharge Perm,�n
General Permit - Existing Animal Waste Operations s
The following questions have been completed utilizing information on file with the Division. Please
review the information for completeness and make any corrections that are appropriate. If a
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
I. GENERAL INFORMATION:
I.1 Facility Name: Bullard Farm
L2 Print Land Owner's name: Ray Bullard
1.3 Mailing address: Rt 2 Box 290-A2
City, State: Stedman NC
Telephone Number (include area code): 531-3463
1.4 County where facility is located: Cumberland
Zip: 28391
1.5 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a
copy of a county road map with the location of the farm identified). 4 miles from Stedman (Hwy. 24) on S.R. 2022
(Stedman -Ceder Creek Road.)
1.6 Print Farm ,'Manager's name (if different from Land Owner): same
1.7 Lessee's / Integrator's name (if applicable; please circle which type is listed):
1.8 Date Facility Originally Began Operation: 01/01/60
1.9 Date(s) of Facility Expansion(s) (if applicable):
2. OPERATION INFORMATION:
2.1 Facility No.: _26 (county number); _7 (facility number).
2.2 Operation Description: Swine operation
mow to Finish
150- Certified Design Capacity
Independent:
Is the above information correct? [Eyes; no. If no, correct below using the design capacity of the facility
The "No. of Animals" should be the maximum num er or which the waste management structures were designed.
Type of Swine No. of Animals
0 Wean to Feeder
0 Feeder to Finish
0 Farrow to Wean (# sow)
0 Farrow to Feeder (# sow)
0 Farrow to Finish (# sow)
Other Type of Livestock on the farm:
FORM: AWO-GE 5/28/98
Tv e of Poultry No. of Animals
0 Layer
0 Non -Layer
0 Turkey
Type of Cattle No. of Animals
0 Dairy
0 Beef
No. of Animals:
DCNR-FRO
162009
Page 1 of 4 26 - 7 DVI

2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): 81.00 ; Required Acreage (as listed in the AWMP): 28.6
2.4 Number of lagoons/ storage ponds (circle which is applicable): 1 (one)
2.5 Are subsurface drains present within 100' of any of the application fields? YES or (please circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES or (please circle one)
2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, NRCS Standards, etc.) (Swine Only)
G
or NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited? 0.1 /01 /60
What was the date that this facility's land application areas were sited? - 01 /01 /60
3. REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
Applicants Initials
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit
application for animal waste operations.
The CAWMP must include the following components. Some of these components may not
have been required at the time the facility was certified but should be adder! to the
CAWMP for permitting purposes:
/3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
✓3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
V3.3.3 A map of every field used for land application.
&,T.3.4 The soil series present on every land application field.
.5 The crops grown on every land application field.
3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
L,T3.7 The PAN applied to every land application field.
v3'3.8 The waste application windows for every crop utilized in the WUP.
PoT3.9 The required NRCS Standard specifications.
✓%3.10 A site schematic.
✓3-3.11 Emergency Action Plan.
+�1:3.12 Insect Control Checklist with chosen best mana?em rit practices noted.
"1.13 Odor Control Checklist with chosen best management practices noted.
& 3'3.14 Mortality Control Checklist with the selected method noted.
wn.15 Lagoon/storage pond capacity documentation (design, calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility.
1--3.16 Operation and Maintenance Plan.
If your CAWMP includes any components not shown on this list, please include the
additional components with your submittal.
FORM: AWO-G-E 5/28/98
Page 2 of 4 26 - 7

Facility Number: 26 - 7
Facility Name: Bullard Farm
4. APPLICANT'S CERTIFICATION:
Ray Bullard (band Owner's name listed in question 1.2), attest that
this application for Bullard Farm _,(Facility name listed in question 1. l )
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned to me as incomplete.
Signature
Date
5. MANAGER'S CERTIFICATION: (complete only if different from the Land Owner)
(Manager's name listed in question l .6), attest that this
application for __(Facility name listed. in question I.1)
has been reviewed by me and is accurate and complete to die best of my knowledge. 1 understand that if all required pans of this.
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned as incomplete. "I
Signature
Date _ .r'a7 /- ;Y
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
RECEIVED
WATER WA tTYSECTION
Non -Discharge Permitting
FORM: AWO-G-E 5/28/98 Page 3 of 4 26 - 7

.n. .�._.::..,..,- .....�... _�,...-..Y..�,: ,. .:....... ..,... ..
A27 IAL WASTE MANAG =T PLAY c3=7 1CATICH FOR :n FEEDLOTS
Please retu= the completed fora to the Division of Ez<visormeatal HaztaQement at
the add --ass on the reves9e side of thia fora.
Name of farm (Please print) : Ray Bullard Farm
Address:, Route 2, Box 290A2
Stedman, NC 28391_ Phone No. 910-537-3463__
County: Cumberland
Farm, location: Latitude and Longitude:3!+° 18—' 1Z /�.Uo_2' Ste' (required) . Also,
please attac:i a copy of a county road snap with location identified.
Type of operation (swine, layer, dairy, etc. ) : Swine
Design capacity (number of animals) :� 150 Sows, Farrow to Finish
Average size of operation (12 month population avg.).- 1275 Total
Average acreage- needed for land application of waste (acres) 2 28.6
aaesaaasaaaaynaaaaaaaaaaaaaaazaassaaaaaaasaaaaaaaaaaaaaoaaaaaaaaaaaaaaaaaaaaaaa _
Tschaical Specialist cartificatiazt
As- a technical specialist designated by the North Carolina Sail and Water
Conservation Commission pursuant to I5A NCAC 6F .0005, I certify that the new or
expanded animal waste management system as installed for the farm named above
has an animal waste management plan that meets the design, constructions:
-peration and maintenance standards and specifications of the Division of
viro=ental Management and the USDA -Soil Conservation Service and/or the Nor
Carolina Sail and Water Conservation Commission pursuant to 15A NCAC 2H.0217 anrS,n
15A NCAC 6F .0001-.0005. The fallowing elements and their corresponding minimum
criteria—have_.been yeti€ied by me or other designated technical specialists anr�f._
are included in the plan as applicable: minimum separations (buffers); liners ofi :2
equivalent far lagoons or waste storage ponds; waste -storage capacity;adequatc3:
quantity and amount of land for waste utilization (or use of third party) ; access
or ownership of proper waste application equipment; schedule for timing of
applications; application rates; loading rates; and the control of the discharge
of pollutants from stormwater runoff events less severe than the 25-year, 24-hour
storm.
Name of Techaical Specialist (Please Print) : John M. Ray, Jr.
Affiliation: USDA -Natural Resource Conservation Service
Address (Agency) . 21 "East Mountain Drive Suite Ln Phone No. 910-484-8479
Fayetteville, NC 28306 � r
Signature: Date:_
ggaaaaaaa�aa a aaaaa�aaaaaa vxsa aaaaagaaaaaaasaaaaaaaaaa�aanaaaaaaa
owner/rsaaager _aemeat
I (we) understand the operation and maintenance procedures established in the
approved animal waste management plan for the farm named above and will implement
these procedures. I (we) know that any additional expansion to the existing
design capacity of the waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the Division of
Environmental Management before the new animals are stocked. I (we) also
understand that there must be no discharge of animal waste from this system to
surface waters of the state either through a man-made conveyance or through
runoff from a storm event less severe than the 25-year, 24-hour storm. The
approved plan will be filed at the farm and at the office of the local Soil and
Water Conservation District.
Name of La
Signature:
Nana of XA
Signature: Date-
-note: A change in land ownership requires notification or a new certification
(if the approved plan 'is changed) to be submitted .to the Division of
Environmental Management within 60 days of a title transfer.
DE4 US' ONLY. Ao ,EW# D

ANIMAL WASTE UTILIZATIpN PLAN
Producer: Ray Bullard
Location: Route 2 Box 296,92
Stedman NC 28391
Telephone: [phone]
Type Operation: Existing Farrow to Finish Swine.
Number of Animals: 150.00 sows
(Design Capacity)
STORAGE STRUCTURE: Anaerobic Waste Treatment Lagoon
APPLICATION METHOD: Irrigation
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops
in the fields where the waste is to be applied.
This.waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply
more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall be applied to land eroding at less than
5 tons per acre per year. Waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on saturated soils, when it is raining,
or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed
under DWQ regulations.
Page: 1

ANIMAL WASTE UTILIZATION PLAN
5. Wind conditions should also be considered to avoid drift and
downwind odor problems.
6. To.maximize the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more -than 30
days prior to planting a crop or forages breaking dormancy:
injecting the waste or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. If
you choose to change methods in the future, you need to revise this
plan. Nutrient levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from your
waste management facility. In some cases you may want to have plant
analysis made, which could allow additional waste to be applied.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
This waste utilization.plan, if carried out, meets the requirements
for compliance with 15A NCAC 2H .0217 adopted by the Environmental
Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
150 sows x 19.9 tons waste/sows/year = 2985 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
150 sows x 26 lbs PAN/saws/year = 3900 lbs. PAN/year
Applying the above amount of waste is a big job. You should plan
time and have appropriate equipment to apply the waste in a timely
manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
Page: 2

ANIMAL WASTE UTILIZATION PLAN
TABLE.1: ACRES OWNED BY PRODUCER
TRACT
FIELD
' SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
----
or
-------
APPLY
RESID.
APPLIC
METH
N
TIME
3299
1
BuA
SB
.35
122.5
0
10.8
1323
I
MAR-JUL
32991-1
3299
3-4 ISt
3299
-3-4
3299
9 SuA
3299
1-9
20
WA
I1
180
S$
I
135
1122.57
WA
1
20
I
1
180
SB
35
122.5
0
I
WA
1
20
I
180
10.8 1864
SEP-NOV
2.4 1294
MAR-JUL
2.4 192
SEP-NOV
15.9 11947.75
MAR-JUL
15.9 �1272
SEP-NOV
TOTALI5892.75
- - Indicates that this field is being overseeded (i.e.
interplanted) or winter annuals follow summer annuals.
NOTE: The applicator is cautioned that P and K may be over applied
while meeting the N requirements. In the future, regulations
may require farmers in some parts of North Carolina to have a
nutrient management plan that addresses all nutrients. This
plan only addresses nitrogen.
Page: 3

r
ANIMAL WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
See required specification 2.)
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
----
or
-------
APPLY
RESID..
APPLIC
METH
N
TIME
END
TOTALI0
Indicates that this field is being overseeded (i.e. interplanted) or
winter annuals follow summer annuals.
** Acreage figures may exceed total acreage in fields due to
overseeding.
* lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and 2 above. -
CROP CODE
CROP
UNITS
PER UNIT
SB
WA
SOYBEANS
WINTER ANNUALS (I.E. Small Grains, etc.)
BUSHELS
AC
3.5
100
TOTALS FROM TABLES 1 AND 2
ACRES LBS AW N USED
TABLE 1 29.1 1 5892.75
Page: 4

ANIMAL WASTE UTILIZATION PLAN
TABLE 2
TOTAL
'a
29.1
Q
5892.75
*** BALANCE (-1992.75 1
--------------------
*** 'This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.
Page: 5

ANIMAL WASTE UTILIZATION PLAN
*** This number must be less than or equal to 0 in order to fully
utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffers, filter strips along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than
the acres shown in the tables.
See attached map showing the fields to be used for the utilization of
animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient
rich and will require precautionary measures to prevent over application
of nutrients or other elements. Your production facility will produce
approximately 645 pounds of plant available nitrogen per year in the
sludge.
if you•remove the sludge every 5 years,
pounds of PAN to utilize. Assuming you
bermudagrass hayland at the rate of 300
will need 10.75 acres of land. If you
the rate of 125 pounds of nitrogen per'
of land. Please be aware that these ar
land needed. Actual requirements could
sludge waste analysis, soil types, real
methods.
you will have approximately 3225
apply this PAN to hybrid
pounds of nitrogen per acre, you
apply the sludge to corn at
acre, you will need 25.8 acres
e only estimates of the PAN and
vary by 25% depending on your
istic yields, and application
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the
soil at the•time of irrigation such that runoff or ponding occurs. This
rate is limited by initial soil moisture content, soil structure, soil
texture, water droplet size, and organic solids. The application amount
should not exceed the available water holding capacity of the soil at the
time of irrigation nor should the plant available nitrogen applied exceed
the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables 1 and 2. Failure to apply the recommended rates and
Page: 6

ANIMAL WASTE UTILIZATION PLAN
amounts of nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application
rates and amounts.
j l
lApplication
RatelApplic. Amount
Tract
I Field l
Soil Type
l crop
(in/hr)
I (inches)
3299
I I
11 l
I
I
I 0.40
l *1.0
BuA
I SB
3299
I I
1 3-4 l
I
I
I 0.50
I *1.0
St
l SB
3299
l 9 l
0.40
I *1.0
BuA
l SB
3299
I
l -1 l
I
I
I 0.40
I *1.0
+ WA
3299
I -3-4 I
I
I
I 0.50
*1.0
I WA
3299
I -9 I
I I
I 0.40
I
I *1.0
l WA
I
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations, the application amount shown cannot
be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180.00 days of temporary storage and
the temporary storage must be removed on the average of once every
6.00 months. In no instance should the volume of the waste be stored
Page: 7

ANIMAL WASTE UTILIZATION PLAN
in your structure be within the 25 year 24 hour storm storage or one
foot of freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply the
correct rates to the acres shown in Tables 1 and 2. Failure to apply
the recommended rates and amounts of nitrogen shown in.the tables may
make this plan invalid.
Call your technical specialist after you receive the waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate prior to applying the waste.
NARRATIVE OF OPERATION
NOTE: Field #9 will be temporarily fenced and grazed during the winter for about 45- 90 days.
Page: 8

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
5. Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina" for guidance.)
7.- Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff.does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be.considered.
Page: 9

c
WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to
wells:
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly into water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
the site.
16. Domestic and industrial waste from'washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc., are limited to areas where considered
appropriate.. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 10

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
18. If animal production at'the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22. Waste shall be tested within 6G days of utilization and soil
shall be tested -at least annually at crop site's where waste
products are applied. Nitrogen shall be the rate - determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when these
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. soil and waste
analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be
maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North
Carolina regulations.
Page: 11

ANIMAL WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm:
Owner/Manager Agreement
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
North Carolina Division of Water Quality (NCDWQ) before the new
animals are stocked. I (we) also understand that there must be no
discharge of animal waste from this system to surface waters of the
state from a storm event less severe than the 25-year, 24-hour
storm. The approved plan will be filed on -site at the farm office
and at the office of the local Soil and Water Conservation District
and will be available for review by NCDWQ upon request.
Name of Facility Owrier:' Ray Bullard
(Please print)
Signature: Date:
Name of Manager(If different from owner):
Signature: _ Date:
Name of Person Preparing Plan: (Please print)Larry E Simpson
Affiliation:Cumberland SWCD Phone No. [phone]
Address (Agency): 121 East Mountain Drive Ste 229
Fayetteville NC 28306-3422
�a
Signature: Z +•—J Date: 3 2 2— g q
Page: 12

ANIMAL WASTE UTILI2ATION PLAN
/R,F Q
R QlAlA YSECTION
% 14AY 2 5 1999
Producer: RAY BULLARD ` Nora -Discharge permitting
Location: RR2 BOB 290A2
STEDMAN NC 28391 �I
Telephone: [phone]
i
Type Operation: Existing Farrow to Finish swine
Number of Animals: 150.00 sows
1
(Design Capacity) f`
STORAGE STRUCTURE: Anaerobic.ZWaste Treatment Lagoon
APPLICATION METHOD: Irrigation
The waste from your animal facility must be land applied at a
specified rate to prevent polrlution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops
in the fields where the is to be applied.
This waste utilization`yplan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several factors are.important in implementing your waste utilization
plan in order tomaximizethe fertilizer value of the waste and to
ensure that it.is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply
more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3! Normally waste shall be applied to land eroding at less than
5 tons per acre per year. Waste may be applied to land
' eroding at 5 or more tons per acre annually, but less than
,r 10 tons per acre -per year providing that adequate filter
strips are established.
4. Do not apply waste on saturated soils, when it is raining,
or when the surface is frozen. Either of these conditions
may result in runoff to surface waters which is not allowed
under DWQ regulations.
Page: 1

ANIMAL WASTE UTILI2ATION PLAN
5. Wind conditions should also be considered to avoid drift and
downwind odor problems.
6. To maximize the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more than 30
days prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. If
you choose to change methods in the future, you need to revise this
plan. Nutrient levels for different application methods are not•the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from your
waste management facility. In some cases you may want to have plant
analysis made, which could allow additional waste to be applied.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
This waste utilization plan, if carried out., meets the requirements
for compliance with 15A NCAC 2H .0217 adopted by the Environmental
Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
150 sows x 19.9 tons waste/sows/year = 2985 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
150 sows x 26 lbs PAN/sows/year = 3900 lbs. PAN/year
Applying the above amount of waste is a big job. You should plan
time and have appropriate equipment to apply the waste in a timely
manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
Page: 2

ANIMAL WASTE UTILIZATION PLAN
TABLE 1: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
------
APPLY
RESID.
APPLIC
METH
N
TIME
3299
1
BuA
SB
35
122.5
0
10.8
1323
I
MAR-JUL
3299
--1
;
WA
1
0
10.8
I
1-100
11080
SEP-NOV
3299
-3-4
1
0
IWA
I
1100
12.4
1240
SEP-NOV
3299
-9
1
0
IWA
I
1100
115.9
11590
SEP-NOV
3299
9
SB
35
122.5
0
JBUA
I
18.5
11041.25
MAR-JUL
3299
9
SB
35'
122.5
0
IBUA
I
15.0
1612.5
MAR-JUL
3299 9 ISt SB 35 122.5 p 12.4 1294
I I I MAR-JUL
3299 3-4 ISt SB 35 122.5 0 12.4 1294
I MAR---JUL
END
I
TOTAL16474.75
- Indicates that this field is being overseeded (i.e.
interplanted) or winter annuals follow summer annuals.,
NOTE: The applicator is cautioned that P and K may be over applied
while meeting the N requirements. In the future, regulations
may require farmers in some parts of.North Carolina to have a
nutrient management plan that addresses all nutrients. This
plan only addresses nitrogen.
Page: 3

ANIMAL WASTE UTILIZATION PLAN
TABLE Z: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
See required specification 2.)
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**.
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
-------
APPLY
RESID.
APPLIC
METH
N
TIME
END
TOTAL 10
- Indicates that this field is being overseeded (i.e. interplanted) or
winter annuals follow summer annuals.
** Acreage figures may exceed total acreage in fields due to
overseeding.
* lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and 2 above:
CROP CODE
CROP
UNITS
PER UNIT
SB
WA
SOY BEANS
WINTER ANNUALS (I.E. Small Grains, etc.)
BUSHELS
AC
3.5
100
TOTALS FROM TABLES 1 AND 2
ACRES LBS AW N USED
TABLE 1 29.1 6474.75
Page: 4

ANIMAL WASTE UTILIZATION PLAN
TABLE.2 0
TOTAL 29.1
*** BALANCE
0
6474.75
--2574.75
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.
Page: 5

ANIMAL WARTS UTILISATION PLAN
*** This number must be less than or equal to 0 in order to fully
utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffers, filter strips along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than
the acres shown in the tables.
See attached map showing the fields to be used for the utilization of
animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient
rich and will require precautionary measures to prevent over application
of nutrients or other elements. Your production facility will produce
approximately 645 pounds of plant available nitrogen per year in the
sludge.
If you remove the sludge every 5 years, you will have approximately 3225
pounds of PAN to utilize. Assuming you apply this PAN to hybrid
bermudagrass,hayland at the rate of 300 pounds of nitrogen per acre, you
will need 10.75 acres of land. If you apply the sludge to corn at
the rate of 125 pounds of nitrogen per acre, you will need 25.8 acres
of land. Please be aware that these are only estimates of the PAN and
land needed. Actual requirements could vary by 25% depending on your
sludge waste analysis, soil types, realistic yields, and application
methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the
soil at the time of irrigation such that runoff or ponding occurs. This
rate is limited by.initial soil moisture content, soil structure, soil
texture, water droplet size, and organic solids. The application amount
should not exceed the available water holding capacity of the soil at the
time of irrigation nor should the plant available nitrogen applied exceed
the nitrogen needs of the crop.
If surface irrigation is the -method of land application for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables 1 and 2. Failure to apply the recommended rates and
Page: 6

s
ANINAL WASTE UTILIZATION PLAN
amounts of nitrogen shown in the tables may make this plan invalid.
The.following table is provided as a guide for establishing application
rates and amounts.
I
I
I
(Application
RatelApplic. Amount
Tract I
Field I
Soil Type
I Crop
I (in/hr)
I (inches)
I
3299 11
I
I
BuA
!
I SB
I
I 0.40
I
I *1.30
I
3299 I
I
3--4 I
St
I
I SB
I
I 0.50
I *1.50
3299 l
9 I
St
I SB
I 0.50
I *1.50
3299 l
9 I
BuA
I SB
I 0.40
I *1.30
I
3299
I
l 9 I
BuA
I
I SB
I
I 0.40
I *1.30
3299 I
I
—1 I
I
I WA
I
I
I
3299
(
I -•3-4 I
I
I WA
I
I
3299
1
I
—9 I
I
I
I WA
I
I
I
I
I
* This is the maximum application amount allowed for the soil
assuming the amount of. nitrogen allowed for the crop is not over
applied. In many situations, the application amount shown cannot
be applied because of the nitrogen limitation. The maximum
Page: 7

s
ANIMAL WASTE UTILIZATION PLAN
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180.00 days of temporary storage and
the temporary storage must be removed on the average of once every
6.00 months. In no instance should the volume of the waste be stored
in your structure be within the 25 year 24 hour storm storage or one
foot of freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply the
correct rates to the acres shown in Tables 1 and 2. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may
make this plan invalid.
Call your technical specialist after you receive the waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate prior to applying the waste.
NARRATIVE OF OPERATION
Page: 8

WABTE UTILIZATION PLAN
REQUIRED SPECIFICAUB
1. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must.be documentation in the design folder that the
producer either owns or has -an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application.. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
5. Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to,
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation'tilled crops or
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. .(See "Weather
and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be considered.
Page: 9

WASTE UTILI2ATION PLAN
RAQUJMD OXECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be
held to a minimum -and a suitable winter cover crop planted to
take,up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm shall be.at least 50 feet from any residential
property boundary and from any.perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to
wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly into water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates in a.manner that causes'no runoff or drift from
the site.
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on'all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 10

WASTE UTILIZATION PLAN
REOUIRED sPECJ ZCATIONS
is. If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22. Waste shall be tested within 60 days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when these
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
•analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be
maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North
Carolina regulations.
Page: 11

ANIMAL WASTE UTILIZATION PLAN
WASTE UTILIZATXON_.PLAN AGREEMENT
Name of Farm:RAY BULLARD
Owner/Manager Agreement
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
North Carolina Division of Water Quality (NCDWQ) before the new
animals are stocked. I (we) also understand that there -must be no
discharge of animal waste from this system to surface waters of the
state from a storm event less severe than the 25-year, 24--hour
storm. The approved plan will be filed on -site at the farm office
and at the office of the local Soil and Water Conservation District
and will be available for review by NCDWQ upon request.
Name of Facility Owner: RAY BULLARD
(Please print)
Signature: Date:
Name of Manager (If different from owner) :
Signature: Date:
Name of Person Preparing Plan: (.Tease print)John M Ray Jr.
Affiliation:MRCS Pbone No. [phone]
Address (Agency): 121 East Mountain Drive Ste 229
Fayetteville NC 28306-3422
Signature: C'��_12& 1 Date:
0 / Vp
Page: 12

4 q•
IYv.w. �_,L, �i. rr• � P" N4,e j
i I
r f
'aYr( �r f F r •
r
° Y
J'+Tk'6p• y., Pam.. Y7•
W.
MN ii e3i �1
hi
;OP
'� Y f �' pm �£ ,r � 'yen} iq�=•ti r`r s-'!r°e1�Si � r ' * a
'� � �.rtr +. •"+•+ei M! Y .'�1 }F� �+t1° 4 4.` y r ` ,�'; d&�' L e .
� f?F�� 4=ri r4 1 1.• ."Y•..j♦ - r.i• i ti �:•.4
iitAP
x `� V' '� �%�a��ffi a� s �• r< �� Ajl ; r�t�X+".� tit} �i ,� +.a `-44' "•.
JA
,�f� �L f ! • 1 �• F .�' i J 1_ �=11� S 5J t a >1 .1?+� '�
tl
=ti '}✓~9 �G� . IF
ys}t* E
-1 i x'•• E',n �5 ` 1 -tr 1..,. �4 '$•r,},yF )j'x'li`yk'n �i'�k _
�;, � i.r Yx --aka ,k�, ,r ~ � � _ �,'" 7 'C ' 7a� t - .,� � EQ ` _ tvi`�� •s
io
s
! 3170
a.,r) �E��� ��� M�
C?' s;," tyFt . t` .�'�
{ ���. r `'L_ •9d� .
Y'hr t
pt n.
t �.� F
r'F .L �•'•LE:
h
4rrt�
'.fir ' i}'.1'' R'' 0» 7•.7
!
,E
��Fd! _
� t .+�
t
_
�a1 Yii' .. ��•�r'1M. w J '� ' r l�•v� H, * 1WA- -[cr' }
Jr
�a,�
IF4.�r 1 r.
.I .J _ F r�`• 1 j
.
\• � 4''1
•
�r'u. ,'1yd°�. m. �.. ,.5. ....ti+ .
>�.... ° `. .. _ , N.i.• w'K°,'"��.C.�f!erAL::�.. `t..a ,`..a:'
� r. .:
4't. L-.:� , rF i ,-. (...
4

' ! - + .`'.3 Y •^ `.!, - - - � L '`1.., i� `� .�1 Yt q. VF C'!i�. y5 1 }' :F,` 1
.y .ti 'y ' � }'' S �� # 'i Itir •� r 1' I Y' x• � y `FL J• � �
� .� .� a, l' y-7y- IIlA + �' IT.1L 1:t:' •sSSr' � r ,-.., �, �r' �
t fpl'i �_ �. �'n �'�'r + r' lI]! y � � � .y 70►. 17/ -Y : -. ,,. }r r ; A ` h lllLi' � •. , ' ?s
`!t _•h• �+'�''` 'r .' r + 'yL .,. � J., ';s $. ,r � r p' '`R-; � �..'.\' ,� ' r tY r�•' `,i.
• �G �` - `+ r ' � lJllek w x.j.�E �!`r �. y � ter . it k � ne �., yF,"X v7{� s sro.^ -[',''
':^ rr' r i ,s•�k i y _' f. ' •- ' � r is r A�� - S '�7i 1�•E5`;1.�1 �r+�R
pfg y, � • �. 5 � a�i+� `^ '.,. ` c ne, x M1N: • �' i r 'r � ' .�A� _ 17 � � y"Y'1� \ iO4
•c � t kk'•Ir [�� ;C4r� - ,{�; �``,,,�- nr n •1' �y 1 ""` 7 - .a �, -pj .'a'11"'.
CrIM L!
VII
f` �R'� � ' !_Y.� t l •�ny�,j L� �`Fr 4i f�, �^I' �`'' -. - .1'' y. M.. 111111
� J _ A. • ra tii��,�� � n It � I, �, � v `+ �l �y tei�T. .c1,. A ., FASu 'R'�• �, .� ry �1
I \1
ti• .. ' � W- t�"i ark y - ^ 9e
l � y -..1• � 7J •p � LiSZ IIAO
Eft. �? E� 1
.I WLL i V.. I
H ✓r 4 �
40
of i2.3
al uU .t Ib 111.E P 1.1
I/14 :all! � ....
Cedes Gwk
k Gwk OL
POP. 773
�ti/A�Is
WMTZ
/ PONO
wd 1
BX
Empee
Ch,
RNTE

WASTE MANAGEMENT PLAN
ATTACHMENTS
A. EMERGENCY ACTION PLAN
B. ODOR CONTROL CHECKLIST
C. INSECT' CONTROL CHECKLIST
D. MORTALITY MANAGEMENT METHOD

EMERGENCY ACTION PLAN
PHONE NUMBERS
DWQ 910-4861541
EN-ERGENCY �[ANAGE'�\/[EyT SYSTEM 910-678-7688
SWCD 910-484-8479 ext. 3
MRCS 910-484-8939 ext..3
Extension Service 910-484-7156
Ties plan °.will be imoletnented in the event that wastes from your operation are leaking.
overrlowing. or running or: site. You should nat wait until wastes read Surface ".eaters cr
leave vour prooert.; to consider that you have a problem. You should rna e ever.: e:lort to
ensure that this does not happen. This plan should be posted in an accessi*:.ie location far
ail emp[ovets at :he faciliV.,% The following are some action items you si,ouid raki!.
1. Stoo the release of wastes. Decending on -the situation. this may or ra. nct e
possible. Suggested responses cc some possible probie:ns are [iszed be!C :' .
A. Lagoon overflow -possible solutions are:
a. a.dd soil to benn, to increase elevation of dam.
b. Pumo wastes cc fiejds at an acceotable rate.
C. Stop all tio51.s to t,e lagoon imme^iate.v.
d. Call a pumcing contractor.
e. tMake sure no surface ware: is entering lagoon.
B: Runoff from waste application field -actions include:
a. Immediately stop waste application.
b. Create a.temocrar_� diversion to contain.waste.
C. Incorporate waste to reauce runoff.
d. Evaluate and eliminate the reasons) that caused the runoff.
e. Evaluate the application races for the tlelds where runoff oc:ur<e_.
C: Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle pump.
b. Stop irigacion pump.
c. Close valves to eliminate further discharge.
d. Repair all leaks prior to restaaing pumps.
D: Leakage from tlush systems. houses. solid separators-ac:ion inc,ud,-:
a. Stop recycle pump.
Stop [rrigallon pump.
C. -slake sure no sichon occurs,
d. Sco❑ all flows in the house. rlcfs;•l systems. or soiid sepurators.

e. Repair all leaks prior to restarting, pumps.
E: Leakaze from base or sidewall of la_�zcorl. Often this is setpa'g3 as opeo<_e:.i t3
tlowin_ leaks- possible ac:ion:
a. Dig a small sump or ditch away from the embankment to catch all :eeoane.
put in a subme:r�ible pump. and pump back to la?oon. -
b. If holes are caused by burrowimz animals. trio or remove animais and fl:i
holes and compac: with a clay tN'pe soil.
c. Have a protessional evaluate the condition of the side wails and lagocc
bottom as soon as possible.
_. Assess the ement of ii e soiil and not.. any ob':ious.darna'aes.
a. Did tine -was:t :e_Ch an'J surcaC!!
b. a.oera cimate:'� ho'.V MUCn "'as reieasea arc rcr "'MaE � ::cr'
c. anv damave ctec. such as e.-nolovee iniurv, or
C. Did the spill leave cite croczr
t. Does tl:e soill CCc.'.nt:c''..l mtl reach Si:"i--ct ac2t s
i. COLiG i iL"I ._.iL "'�::t C_L'Se ti e ]Glll tC .�zCn _L::.CCe '•''_._.� .
c .-`^.:e vCt ole '.Y_.... •'�:'; ...: a�:ger �z:C:^.e: Gn Cr 1:.. �:i i::..._ "•��. ..
DLrna nCi-".C•l:SineSS i�flL:S, C=.'1 'JQLr D���Q �::1''LSiGn C: w:_" �•'1C..
Your phone call <-4:ould incluCe: vCur- hart te:e�:hCre [ L'nC�r..'�
oC the incident Crom liern 2 ..6ove, the e,:ac: location o{ the tac;kir:, t;.e icca:;lc
direction of rnovernent of :+d soiil. weather and wind condicicns. T::z corec:i %e
rre=Ures that have been under taken, and the se-iousness oC :ice
b. If spill leaves prcce. << or enters surace waters. call local EMS ?hone
c. Instr-act E•ti1S io contact local Health Depat gent.
d. Contact CES. phone number - - local SWCD office phone nurnce-
and local MRCS ofrlce for advice!teciinical assistance phone numbs; -
If none of the above works call 911 or the Sheriffs Deuarmenc and e ;olaln voLr
problem to them and ask that person to contact the proper agencies for You.
5: Contact the contractor of your choice to begin repair of problem to minimize off -sits
dsrnaec.
a. Contractors Name:
b. Contractors address:
c. Contractors Phone:

6: Contact the technics] specialist who cercified the lagoon ( RCS. Consultin'T
Engineer. e,c.)
a. Name-
b. Phone:
T: Implement procedures as advise. by
reccif%, the damage. -repair the sYscem
keep probiems with release of wasces
D%VQ and technical assi;cance agencies tc
and reussess the wasce manag?,Melt plan to
from happening again.

Swine Farm Waste Management Odor Control Checklist
-- Surcc —
u
--�C:1use
T..
iinil's (it Alillimize 011ur Sifc . lecific 1'rnrliccs
Fal.n1SICil !
0 Swint: litoductiun
or woullctl Iluf em,
'
,�.,�Wgd-,klivc
1_'T 1tectillilliell ed best 111:111i1gell1Cllt I1lactices.,
[W--((-i1,O l jutfgulcnl ;Ill( L'OIInIIUn Sl'IISL'
Aiii111al hlltly smfaces
• Dilly Iltallllle-covc1ml allilll:(s
f9 1)Iy flools "-
I'lillli sill faces
• Ii'C{ 1l1:111 RI C-L'uvCl Ctl 11uUl5
l4� .lfUl{C( lloots;
t 11' Ilcicls IUca[Ctl over 511MC l Nutlls;
F-4--1-ved is;il high cull ofsulitl hoot..;
(Matte manule hlliltlull loin fluids;
'
(41 ulldvl Iluir velliilaliull fill. drying
N-1:11111IC CUIICCIItill lll[S
- Udilll -,
ICtI11C111 11wil a I'emoval by 1111sh, pit lechal-ge.
• hi I I i.i I llliclullial tEcrnnlllusilinn
scl;lllc;
���i]
['T UmIcillum veiiii1oHill
VClllllalillll C\ha11St fa115
• VUlalil[_' d:1.iCs;
_ In:1lnlClk;lllCC; —
DIIsl
�—r-ml
I_t Fllicicnl air In11Vcillcul •-
IIIIIUtIrSlll.laCCS
• I)lla
11-4---�V� 15ltdti VII f)C11t't:Cll l;Imili5 of anilli.1k: -'—--------- ----- -
I`"Y I'Cl'fl ;IlilhllVCS;
Cl Icr covers;
f�Zl LlClIVCI)' (UW[1SIMIlt C](lClitlCl'S IU fCC(crl
_
Covel s
Flush lanks
• Agitaliun of Iccyciclf lago(m
Cl Flush lank COYCrs;
lilpll( while laliks ale lllliol.,
UL-- XlCllll fill lilies IU IICar 1101111111 iI MIkS With
-a1111-sillholl Vents
1'lllsll alleys
aAg11atioit dming wusiewaler
U—t' IlllCrllom Iltlsh with U11tltllfltltll ventilation —
COMICy;111ce
pitlecll.alge lluillis AI{ilatitm of lccycicif laguun ;�Icull lcclrugc lines [u near In111un1 trf Mils ----
litlui( Whine hits ale filling With auli-Sillholl %'Clits
Fill slatiulls Agilal ion (llfldlg SUII11i 1a111; CI Sillill lank cuvcls
filling au( llratv(uttn
Outside (lain collection Agi{alion (Ilrhig 1va-Mewaler (71 Ilo.s co%.Cl.s
01'P1110601) hUSCS volkvey.111ce
AhIOC- November 11, 1996, Page 3

Insect Control Checklist for Animal Operations
Source Causr ---�-� --- IIl111's It, Cuntrvl Inserts-- --- Sitc Sln:cific I'raclice,
�Liquid Systems v~�
I lush (;ullcrs A(:el11ll1da11Ulr ill solids Flush sy.Sll'Ifl Is Clesigned and ulletated
Slllllcicnlly to lcnlove accurllulated solids llotn
' l'[5 as designed.
11 !:move bI idgilll; of accmutllalc(I solids al
cti,' 'Ir,ugc
L;It-v nls and l'ils • (-,tosIC(I Solids N'lailllaiu higoulls, wIllilig ba5llls anti Mils Miele
pest blectiug is :ylpatcnl to miuililize Ills
cltlsling of solids to a dcplll ul'nu illurc than G -
8 inches over mule Ilum 3U% ol'surlace,
Excessive Vegetative Ucca)'ing veglclat 011 hlaiulaill vegcla[ive cuultul alullg banks of
Gtowill laguulls and other irnitullndulcnts to prevent
acculnlllation of decaying vegelalive matter
aluog watel's edge oil impoundment's perimeter.
Dry Systems
Feeders Deed Spillage Design, operate ;Intl Illainlain Iced syslclus—
bunkas an(1 hunglls) to minimize [Ile
❑ccunlulatinrl ufdecaying waslage.
171 Cle:ul up spillapc on a 1'tnrline basis (c.g., 7 - IU
clay interval dill hig summer, 15-30 day interval
during Ivintel).
Fced Storage •. Acculnulaliolls ill lcu(I Icsldue5 vIZCduce Illuislllle act lmilladull within and
aroullil inunediale perimeter of lied Storage
areas by insul ing dlainage :Tway 110111 site
anti/or providing adequale containlrlcnl (c.g..,
cuveled bin lur blewel's Blain and sinlil:u high
nluislt le rlairl producls).
17 hlspcct I -Or and lcnlu�e ill- lucak ill) accumulated
Solids ill lillcr strips around feed 51ulal;c as
ncedcd.
AN-11C - November 11. 1996, Page i

5nnrce
— —C :1115C —�
-��—
i.n..'S In Cunlrol Insecls V ue SI1cdHc I wadit _
Allilllal I lulllin6 Areas
• AL'Cilillnhllinlls MAW wusws
❑
llliln111:11c kn :u"s 111:11 imp nIoWt a clung
and Kell %v:tstilgc
I�'cI1CCs and other locations 1\hele waste
•
accunitlhills atul AM hancc by auhnals Is
IIIilIiIII;ll.
"
CI
Main I;Illi ICIIcc Iows al III [iIle r S I I II)s :I1u1111d
animal holding al'Cas In Inininli7.e
acculunhilio115 of 51asluS (i.e., inspecl Illy and
I'C1110%le (ll111Cal, III) acullliltllmed 5olnls as
Ilecllell).
01y MaIIIllc I Imallntg
• AcCumulallnns of alnnlal 1Vastes
[I
RC111nVe SIIIIIaj,-C oil tl lontilIC klSi5 �C.�',., 7 - 10
Systems
Ilay inlel Val lhn ing stulnlcl ; 15-30 clay inlcl vai
din ing willicl ) Miele 111anulc is loaded for land
applicaliun ur disposal.
I'loAN Or acicult:tic lllainal;c:ununcl n1:tlulc
stockpiles.
f7
Inspect I'm ;uid Icutnve ur hrcak III) acctniulaled
%VasICS in litter sh ills asomid stockpiles and
Ili:lllnle Italidling areas as Ilectled. "
I-'ur more inl(IIIJU iion cunlacl the onlieralive Exlcllsiun Noviec, Dgmiluma of I:nlmnoh y, 111)x 7613, I401111 Ca10li11:1 SWIG Univer5ily,
Raleigh, 14C, 27695-7613.
AMIC - November 11. 1996, Vage 2

f
Mortality "Management "Methods
(cheek which methods} are being, implemente:l)
Burial three fee: beneath the surface of the eround within ?' hours. after
knowiedQe of the death. The burial must be at least 300 feet from any flowin=
stream or public body of water.
Rendering at a rendering plant licensed under G.S. 106-165.:
.� Complete incineration
J In the case of dead poultry only. placing in a disposal pit of a size arid. dzsizan
approved by the Deoartment of �.arlculture
:a.nv method which in the processional opinion of the &22 e V�terinarlan :L',�u, J
make possible the saiva_.,2 or part of a dead animal's value Without en an?_.in-
human or animal health. {%Vrittzn aoarovai of the Sate V--terinaria, must be
attached)
a
De. e:nce: l S. 1996

" i.
'COMPUTATION SNffaT r
8C"MG-623 Rev. "9
a s. v-ftAR7xs1Vr Of AaivicuLruRB
OWL L. ;r4689VAWOM SCHVICL
IV
71- TIT
� I
ISO. saws
fQ Ma jrP4.s .WAsrr... AGC"M."t.Ar/oni
a86,�? 1C /ao_ dais a S/,.6SGFri
RRFR 3,. 16 0 _ FT x—
r
.Sra.e M_ SToR�
F
3X.b
0
5�-�(a{•
7r;
�7Y_MP#4
_!
41
if J_LiL.Q rr3

77-7-1-
(7�FIY
do
?v I 4rV %0 7 tv-9
001 It ALE -c a.-7NJD)5'3q JWM7017
9�6 (73CYInO IWO 70A
0 0 6)
t
n
C?
wo 4 kmv."Ofj do-
dU 00 641
Af vidop
=0
...........
060
.3W
JF*fAMM NOU WAMZRF- 1 71106
I
XdfU'InOlWDV jfO 4NZMAoMW*..wd
!" *Afif Ct"Nj-Ls*v
A=ms NolivAndkcm -
11

f � �
leJ�ti./�P-+e rwC�—ter �rYr � w J•...�-s ^�^-'^--. �fsx�-. •._^v. �
-ts---'-
.em

SHEET 1 OF 'w
OPF_RF, . I ON ARID MAINTENANCE PLAN
-------------------------------
This lagoon is designed for waste treatment (permanent storage) and
180 days of temporary storage. The time required for the planned
fl�_tid level. (permanent and temporary storage) to 6te rea(::hed may Vary
dUe to site conditions, weather, flushing operat.i.ons, and -the -.amuc,knt
of fresh water- added to the system.
The designed temporary storage consists of 12.0 days Storage for;
(1) waste from animals and (2) excess rainfall after evaporation„ AliS�()
included .is storage for the 25 year - 24' hour storm for the location
The volume of waste generated from a given number of animals will be
fairly constant throughout the year and from year to year, but excess
rainfall will vary from year to year. The 25 year rainfall will not
be .a factor to consider in an annual pumpiM3 cycle, but this storage
volume must always be available,
A maximum elevation is determined in each design to begin
pumping .and }his .is usually the Outlet. .invert of pipe(s) from
buiIding( a). If the OLttlet pipe is not installed at the elevation to
begin pUmping a permanent marker must he installed at this elevat-i_on
to indicate when pumping should begin.. An elevat_ion mUst be established
to stop pumping to fnainta.in lagoon treatment depth.
PLImping twan be started or stopped at any time between these -two
elevations for operating ccnvenitence as -site conditions permit, such as
weather, soils, crop„ and cegUipment in order to apply waste without
runoff or leaching.
!wend application of waste water is recognized as an Accept.abl.T
method of disposal. Methods cf -application include solid ':_,et,
center pivot, gt.tns, and traveling gun irrigation. Care Should be
tak-e-n when applying Waste to prevent d.amaage to crops.
The following items Ward, to be carried out.
1. It is strongly recommended that the treatment lagoon be pre --
charged to 111^ its capacity to prevent e::r'ess.i.''de odors d�.lring
str+r" -up. Pre -charging redui_es the fCont:F=ntrat.1.on (:)"i' the in1'tia].
wa.ete entering the lagoon thereby redt..Lcing odfars. Solids shOUld be
covered with effluent at all times. When precchtarging is complete,
flu--h buildings with recycled lagoon liquid. Fresh water should not
be used for flu:.ahing, "after initial filling.
Tlae attached waste Utilization plan shall be fol:Lowed. Tlii.s
plan recommends sampling and testing of waste (see attachment)
before land application,
3. Begin temporary storage pUmp-out of the .lagoon when fluid level
reaches the elevation•, 47.6 as marked by permanent marker. Stop pumr.a-
out when the fluid level reaches elevation 45.6 . This temporary
storage, less 25 yr- 24 hr storm, contains 71610 cubic feet or
53564.3 gallons.

SHEET 2 OF 2
4. The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended ma,,iMLAf7) appl.i.cat-ion rate is 0.3
inch per hour-. Refer to the waste ut.i.l.iz4:ttion plan for further -details.
5. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain -a vigorous stand.
fir. Repair any eroded areas ar areas damaged by rodents. and
establish .in vegetation.
7. All surface runoff is to be diverted from the 3.aaoon to stable
Outlets.
8. Keep a minimum of 25 feet of grass vegetated buffer aroLl.nd
waste ut.ili2ation fie?ds adjacent -to perennial streams. Waste will
not be applied in open ditches. Do not pump within 2C)(D f�--�et o, a
residc_�nce or w.ith.:.n .IC)C) feet of a well.. Wastr._ hall be applied in a
manner not to reach other property And PUbl c: ri ght--of-ways.
9. The Clr,:-zkr Water r,ct of 1 =77 prohibits the discharge, of
prnl lut,�tnts in Lo waters of the United States. .l 1. ie Department of
Environment.. Health, and Nzktural Resources, r°ivision of Envircn-
ment.al Man agement, has the raspons.ib.i 1 ity for enforcing this law.

^ '
- A3+NC 9/7/88
° (
'
US Department of Agricu|ture
Goi\ Conservation Service
~ a supplement to the
. WAGTE M A N A G E M E N T PLAM
prepared for
F: THR Li U :EL w'-:J
�n
Cumber|and County, North Car o|ina
Designed by : Jmr Checked by : _____---- _____
Da te : 02/13/91 Date
The fo||owinS computations are oased un using a
rectanSu|ar an�erobic ia3oon to cnntain the annua/ waste
frum e Fo/iowin3 setup:
150 farrow to f�nish, w/ ave. wei8n-� of 1417 |bs,
producin3 1.34 -cu.ft./l000 ibs/aaimFO/oay.
46.4 inches of annua| rainfa||.
6.inches of rainfa|| for a 25 yr.- 24 hr. event.
1 foot of freeboard.
r-
,efore stora3e and disposa| /osses, this se�cup can,
be expected to produce the foi|owinS nutrients:
N 37239 1bs./yr.
P O 25 2! T,602 |bs./yr.
K2 O 25602 ! Lis ./yr.

i 4 � �
Ray LIuI l and (supp, I ernent pig. 2)
MANAGEMENT FACTS:
This analysis presumes that the waste wiII be stored in a
anaerobic lagoon and will be irrigated.
The initial start --up- of a i agoorr is c r i t i c a i. Each
Iagoctn has a calculate, (ainimum design vr,iume (IYIDV). I
manure i ciad i rig keg i ris in the fa i I or winter-, the MDV
( 15891374 ga I I.tns) , roust be f i l 1 ed first. When I oa.d i ng
ties iris at any other time, at least 1/2 cif the minimum
ties i gn vct I ume must be i n the I agoon pr i or to I t+ad i rig .
Once thre I a9-.-,orr i s be i ng use+_-€, i t shr,u I d never lte
evacuated to less than the rn i n i murn ties i gn vo I erne .
Fa i I ure to do any of these i terns may resu i t i n roar
F, r .t tt I e m s.
!Manure and wastewater shctui d tie i toadet :in a Ccirlt i nuOus
l:tasis. Dar I I ading Is desir-ah1Ie. Slug Ictadirig may
ceaijse iodor P,r0b 1 erns..
The d i i ut i.tn vct i ume (DV ) and t+le arinua I manure a n a
wastewater vc] I ume must be spread on the I artd each year.
Regu i a year I y d i i ut i ctn rif I agt: nrr c .tritents i s esserlt I a}
f 1:1 r- tj 1 r c a n t r- .i I,
Dur I rig tree c ourse cif cone ysa.r, t''i I s I a9t_ c,n -4 i I I
5 :=_rr-e 11rt i,ft _:_,!_,_!..°F.^ gal 1 iiris iif 'Wtjste arl7 water thi i S
VQ I erne riC eS ri•tt ! r'!c I ude tr!�? Tn i i'i ! mum des i 'a, vci i uIfTe J i'!' i. r'
tc, empty l r'!'-� the i a.'•joc,n, I t shlctu i d Cie i n i t l a 1 l y a i t a t e d
=:=r- at I east 1 d ay. Add i t i circa i ag ! ta-c; i r,n ma.y Fie rieedeti*
dur i no the empty i rig process .
Cn'r.tuvici crtnd i t i runs rieed trt t,e e v a I uated Pr i t:tr" t•, be'g i rin i rrg
irrisation. Ex, cesslveiy we't ror'dit1 ,ns :,r e'x,r- c-sslvely dr"y
ctortt:! I t i.tris shctu I trr tie avto i ded, s i rice waste ma.y e I thler" run
riff or f low t h r u cracks to sub surfa4:e draina-.3e 5ysterns.
W i nd c cLrid i t I ctiis s'Innu i d be r,bSer-VPd t0 ct.v0 i d dr l -'i; i.+.nIJ 0 d1:1r
rtrc,b I erns . Suhtsurface 'out I e t s and driwnstrearn dr-a i na•3e
51h c.,u I i:I "-re c1:1 nst a.nt I y mon i tored. ,
Ma,x I murn app I i cat I --!n rates shctu I q cons i aer the I rrtal•;e
capab i f i ty of the part i cu I ar sct i Is that the waste i s
apI:t I l eta t_!n. 1= in r mtDst su i i s, a r e c u m m e n d e d rnax 1 m u m
apPi l i cat i con rate i s 0.5 i nches.
Using i rr i gat i con equipment pumping 50f.) gal I on per minute,
empty i rig the I ag oorr wuu I d requ i re appraxx i mate i y 7S
htours oaf pump i rr',3 t i m e each year. ( nr.+t i ric I ud i ng a i tat i on
cir mc,v i rig r: f et_Iu i p m e n t )
c

4
Fray Bullard (supplement pg . 3)
act W A R N I N G
The following analysis ipc i udes only 43 r of the waste
that is generated from the described operation. Additional
land will likely be needed to dispose of the remaining waste.
WASTE UTILIZATION IS LASED ON THE FOLLOWING CROPPING PATTERN:
CROPPING PLAN:
crinpo units acres yield applic. appli.c.
h i story rate
Corn (Lu) 81 125 0.46 inches
NUTRIENT SALANC:E: Initial Amount remaining in Storage
Volume c u . f t . (gal) 315995 ( 2360646) 18074Z ( 1 _;5194 f )
Nitrogen l Fps . 4096
P'ZOT I b s . 12801 7 2*
r•:20 10s. 19201 10982
NUTRIENT TOTALS: Lbs Applied / ac . (L bs Used /ac . )
Carp, acres N I* 05 KZO
Co r n 81 22 ( 175) 68 ( 69) 101 ( 1 6)
DISPOSAL CALENDAR:
Crop, Ac. Jan Feb Mar Apr- May' Jun Jul Aug Sep Oct Nov Dec
Corn 81 NNNNNNNNNNNNNN NNNNNNNNNNNNNNNNNNNNNNNNNNN NN
N= NOT a recommended disposal per l od

•
SCS-CPA4= 1, Name and Address) neon 2. Date of Request
di SollCo •etlan8ervlcs 11.881 ,' • -•
_ Ray Bullard = May 23, 1988
HIGHLl1C}iERODIBLE LANDSAND WETLAND C 1 _1rAb f ' Bo 290pg' °'gym 30
CONSERI/AT10N'-DETERMINATiON 2�` StFeidman;sN.�C:ee283.9I 3. County
• - ,�lurw Cumberland
4. Name of USDA Agency. or Person Raqumdng Determination G. Farm No. and Tract No.
ASCS' " 927 T3299'._
SECTION I — HIGHLYlERODIBL'E
LAND.
6. Is soil survey now available for makinip a highly erodible land determination?
Yes
No
Plaid No.(s)
Total Acres
7. Are there highly, erodible boil map units on this farm?r
S. List highly erodible fields that, according to ASCS records, were used to produce�cs,
an agricultural commodity In any crop year during 1981.1983.
x: x `'
9, List highly erodible fields that have been or will be concerted for the production of
agricultural eommodltles and, according to ASCS records, were not used for this
purpose in any crop:yaar during 1981-1988; and ware not enrolled In a USDA
Hide or dhrersion roam:-
y'}x%,
`{ f•:;
10. This Highly Erodlbla,Land detarminatlon was completed In the: office Field
' 3l. L" 4riirlL�, L1 . is • .'. V, J 3 a
NOTE: If you have highly erodible cropland fields, you may need to have a conservation plan developed for these fields. For further Information, contact the
local office of the Sall Conservation Service.
n. r s4-. 'n-- 1 i 1
SECTION 11 —WETLAND
11. Are there hydric soils on this.form7.
13 you-. Cil��. fli M.l'tEt. at".i-•i.�':i---:J.�.
Yas4
•?� Nq �.f!
-� tField No la)
Total Watland Acres
, -t!
1;nA.-y
wY' >:h r'•x f
'< 77
•+>i«!', s:fi:.ni-- f•! ri�ti r.•.a wRi'4.1 ri• - "•
,.
List field numbers and acres, where appropriate,�for.the followln9 it i, 1 r 71
f
{
EXEMPTED WETLANDS. w
>'
12. Wetlands (W), including abandoned wetlands, or Farmed Wetlands (FW).
Wetlands may be formed under natural conditions. Farmed Wetlands may
be farmed and maintained:In,tho mme monitor. an they were prlar. to + +,
«<ra
December 23, 1988,,as long,as they are not abandoned.
s
asy
13. Prior Converted Wetlands (PC) -The use, management, drainage, and alteration
of prior converted wetlands (PC) are not subject to FSA unless the iron reverts
cr
-
� Q
1J
n z z F
f{
to wetland as a result of abandoriment..�Ycu should Inform SCS of any arcs to
1 ; * <
' " .`
1
z yf
be used to produce an agricultural commodity that has not been cropped,
managed, or maintained for 8 years or more,
x r f
G -�_x ma • �� r .i ... .- -n,->3fi#r:4.`
""E::,i;,-
.f;: " #:�.yv -
14. Artificial Wetlands (AW)-,Artificial Wetlands includes Irrigation Induced wetlands
Theme Wetlands are°riot #ubjeofto FSA.
ua
a }
15. Minimal Effect Wetlands (MW) • These wetlands are to be farmed according to the
f
minimal affect auraament sigriod at the time the minimal effect determination
'<{
was made.
4".1
NON -EXEMPTED WETLANDS; i , i'
16. Converted Wotlands,(CW),• In.any year that an.agricultural•commodity Is planted
on those Converted' Watlandss you will'" 1nellpible for USDA bornefin. If you
x }< s
believe that the conversion was commenced before December 23, 1985, or that
at
the conversion was caused by a; third party, contact the ASCS office to request a
#
a
commenced or third `party"determination...
x yf
x
17. The planned alteration measures on wetlands In fields are considered maintanance and are In compliance
with FSA,
18. The planned alteration measures on wetlands -in fields
will cause the area to become a Converted Watland (CW). Sao item 16 for information on CW.
are not considered to be maintenance and if Installed
19• This wotiand determination was completed 1n the: Office MField Li
20. This determination was: Dellverad Mailed M To the'Person on Date:
NOTE: If you do not agree with this determination, you may request a reconsideration from the portion that signed this form In Block 22 below, The
reconsideration Is a prerequisite for any further appeal. The request for the reconsideration must be In wrlting and must state your reasons for the request.
The request must be mailed or delivered within 16 days after this determination is mailed to or otherwise made available to you, Please moo reverse side of
the producer's copy of this form for more Information on appeals procedure.
NOTE: If you Intend to convert additional land to cropland or altar any watiands,you must Initiate another Form AD-1026 at the local office of ASCS.
Abandonment Is where land has not been cropped, managed, or maintained for 6 years or mare. You shouid inform SCS If you plan to produce an
agricultural commodity on abandoned wetlands.
21. Remarks "This farm contains HYDRIC SOILS. A wetland determination will be required before
draining, clearing or other alteration of a wet area for the purpose of planting
an agricultural commodity."
22. Signature of SC;S-B+sJrlctC9hsorvotlonIst 23. Data
Assistance and pjAl"grafns of the Soil Conservation Service a Ile wit Bard to race, religion, color, tax, age, handicap, etc.
`� SCs Copy