090181_CORRESPONDENCE_20171231

NORTH CAROLINA
Department of Environmental Qual

It
i
RECENED
J U N 2 5 1997
FAYETTEViLLE
:F,EAy OFF�cEBROWN' S OF CAROLINA - FARM 92
10- (800) FINISHING
STATE ROUTE #1315 - BLADEN COUNTY
QBSP# 23-39-07-19
.A +
1'1
i
r_
mo
Lul
'low
-1
,-
r,
J
ti;; ww.006 -
i^■
ems,
,till
f 13
TM 1■m
pan
! �
U!s
su+
131
•�
LM » T2
r
DIRECTIONS: FROM ELIZABETHTOWN, TAKE HWY #87 TO TAR.HEEL.
TURN LEFT AT CAUTION LIGHT ONTO STATE ROUTE #1004. AFTER
APPROXIMATELY 1.5 MILES, TAKE LEFT ON STATE ROUTE #1315. FARM WILL BE
ON LEFT.
MAILING ADDRESS: SHIPPING ADDRESS:
BROWN'S OF CAROLINA BROWN'S OF CAROLINA
P.O. BOX 487 STATE ROUTE #1315
WARSAW, NC 28398 TAR HEEL, NC 28392
[phone] CONSTRUCTION
(910) 293-36M PRODUCTION
BROW N'S OF CAROLINA, INC.
303EAST COI I_EGESTREET - PO. BOX 487 • WARSAW, N.C. 28398-0487 - OFFICE: [phone] - FAX [phone]

Animal Waste Management Plan Certification
i :,:.as -pe or print all information that does not
requir
Extstirt� `or Newar is
Exaii
plese crdede
ry
Namne of
z
Owner(s) Name: AieVi Al O` 4fA40L/AIA, /A/C
Mailing Addres
acility No: 01 _.- Al
hone No: 1/9- z�_-?~ 09,W
Farm Location: Fourteen Digit Hydrologic Unit:_ ii d 0 Z-0 3 // U 0 Z i
Latitude and Longitude: W �3. � �Y 1 �` �, •• County:
Please attach a copy of a county road map with location identified and describe below (Be spec: road
names, directions, milepost, etc.):
Operation Description:
Type of Swine No. of Animals -
0 wean to Feeder
,gFeeder to Finish TQQ0 T_
a Farrow to Wean
Q Farrow to Feeder
:) Farrow to Finish
Type of Poultry No. of Animals Type of Cattle No. of Animals
7 Layer 0 Dairy
© Pullets ❑ Beef
Other Type of Livestock: Number of Animals:
.', Previous;esr =a awr`" > �.Addtrta� D ri aca } s }
S" y
p dap
Th /�/• pry. /ems /} � t A
K.
F�•{fs„Q��wwr.s� �]]�CTIIIlpi!\ /]Rj„ t�5� } �i{.`ti }YS hr y
,: J} { ��.�.•.44 .C-'---"'.T�' M..w4�e��ISF!'iFi�Ol:- fie `t `} - ati Qn.wtIICh _1''=1 a�Ipjled 4MrreKLCZ. tiQn)
<�
Acreage Available for Application: Required Acreage:
Number of La -cons / Storaze Ponds: Total Cap aci Cubic Feet (ft3)
Are subsurface drains present on the farm: YES or NO (please circle one)
Owner / Manager Agreement
I (we) verify that all the above information is correct and will be updated upon changing. I (we) understand the epemtion and
maintenance procedures established in the approved animal waste management plan for the farm named above and will
implement these procedures. I (we) know that any expansion to the existing design capacity of the waste treatment and
storage system or construction of new facilities will require a new certification to be submitted to',&e Division of
Environmental Management before the new animals are stocked. I (we) understand that there must be no discharge of animal
waste from the storage or application system to surface waters of the state either directly through a man-made conveyance or
from a storm event le;s severe than the 25-year, 2A hour storm and there must not be run-off from the application of animal
waste. I (we) understand that run-off of pollutants from lounging and heavy use areas must be minimized using technical
stand-ards developed by the Natural Resources Conservation Service_ The approved plan will be filed at the farm and at the
office of the local Soil and Water Conservation District. I (we) know that any modification must be approved by a technical
specialist and submitted to the Soil and Water Conservation District prior to implementation. A change in land ownership
requires written notification to DEM or a new ction (if the approved plan is changed) within ba days of a title transfer.
Name of Land 0 er : svn.,s ertif caL e- LE^ /S r5t
Signature: % Date:
Name of Manager(if different from owner):
Signature:
AWC -- April r-t, 1996
Date:

Technical Specialist Certification
I. Asa technical specialL esignated by the North Carolina Soil : Water Conservation Commission
pursuant to 15A NCAC 6F .0005, I certify that the animal waste management system for the farm
named above has an animal waste management plan that meets or exceeds standards and specifications
of the Division of Environmental Management (DEM) as specified in 15A NCAC 2H.0217 and the
USDA-NaturaI Resources Conservation Service (MRCS) and/or the North Carolina Soil w,d Water
Conservation Commission pursuant to 15A NCAC 2H.0217 and 15A NCAC 6F .0001-.0005. The
following elements are included in the plan as applicable. While each category designates a technical
specialist who may sign each ce:-Lif:cation (SD, Sl, W`UP, RC, 1), the technical specialist should only
certify parts for which they are technically competent.
IL Certification of Design
A) Cnllection. Storage. Treaftnng_nt System
Check the appropri=e box
U Existing facility wirhout retrofit (SD or Viup)
Storage volume is adequate for operation capacity; storage capability consistent with
waste utilization requirements.
New xpanded or retrofitted facility_ (SD)
al waste storage and treatment structures, such as but not limited to collection systems,
lagoons and ponds, have been designed to meet or exceed the minimum standards and
specifications.
Name of Technical Specialist (Please print):P- t//Soh/ - -
Affiliation: d� t.S_ OF L'1fPc e- !/tip
Address en c - /� --z13 -Z-g9V
(' a �:}�o x 7 , G_ es � 3 �B phone No.: to
B) Land.Anb Lion Site (WUP)
The plan provides for minimum separations
utilization; chosen crop is suitable for waste ma
Name of Technical Specialist (/P%lease Print):,
Address( cy): P o1z I
Signature:
C) Rungff nVr!jsfrom i is
Check the appropriate box
(buffers); adequare amount of land for waste
agement; by ulic and nutrient loading rates.
VAkoAJ
0 Facility without exterior lots (SD or WUP or RC)
This facility does not contain any exterior lots.
Z �-3 5 3 phone No.: �- 29 3 . Z� �
,a _ V-^ g
❑ Faciliry with exterior lots (RC)
Methods to minimize the run off of pollutants from Iounging and heavy use areas have been
designed in accordance with technical standards developed, by NRCS.
Name of Technical Specialist (Please Print):,
Affiliation: URA.'nis
C 2�R3 i
Signature
AWC -- Ap—rIT?4, 1996 2
to No.:
A111 l 7`— '5FG

D) Aooiicatiorzand HaOLUine EquilImpnt
Check the appropriate box
0 Existin- facility with existing, waste application M ment (V UP or I)
Animal waste application equipment specified in the plan has been either field calibrated or
evaluated in accordance with existing design charts and tables and is able to apply waste as
necessary to accommodate the waste management plan: (existing application equipment can
cover the area required by the plan at rates not to exceed either the specified hydraulic or
nutrient loading rates, a schedule for timing of applications has been established; required
buffers can be maintained and calibration and adjustment guidance are contained as part of the
<New
lan).
LAY or ex a ded facility: or existing facility witho t exi ring waste alicarin equipment (1)
Animal waste application equipment specified in the plan has been designed to apply waste as
necessary to accommodate the waste management plan; (proposed application equipment can
cover the area required by the plan at rates not to exceed either the specified hydraulic or
nutrient loading rates; a schedule for timing of applications has been established; required
buffers can be maintained; calibration and adjustment guidance are contained as part of the
plan).
i V1
Name of Technical Specialist (Please Print):
AfRliarinn--RoP iaA Or- P A4f)L f AbIr
No. i ►o Zq3 2-96 V
Signature:
III. Certification of Installation
A) Collggtion. Storagg. TreatMent Installation
New, expanded or retrofitted facility (SI)
Animal waste storage and treatment structures, such as but not limited to lagoons and ponds,
have been installed in accordance with the approved plan to meet or exceed the minimum
standards and specifications.
For existing facilities without retrofits, no certification is necessary.
Name of Technical Specialist (Please Print):
Affiliation: } I&L�A S OF / f lfD L-f _1 A-
Addres cy): i -t 1� ox `� 7 1,1�f�Qs Atd1 A/C ZW 3; Phone No. I1 t o
Signature.-x-»x-�' Date:
AWC -- April 24, 1996 3

B) Land AD iikation Site (WUP)
Check the appropr=e box
ZI The cropping system is in place on all Iand as specified in the ant -Al waste management plan.
W Conditional Approval: all required land as specified in the plan is cleared for planting; the
cropping system as sperm fled in the waste utilization plan has not been established and the
owner has committed to establish the vegetation as specified in the plan by
(month/day/year); the proposed cover crop is appropriate for compliance with the waste
utilization plan.
so check this box if appropriate
if the c-.oppin; system as specified in the plan can not be established on newly cleared
land within 30 days of this certification, the owner has committed to establish an interim
crop for erosion control;
Name of Technical Specialist (Please Print): 7rzow.. s J C.�-�� L--�•� �•
Affiliation: 1�3/ a w t` S d
Signature
This followz ignature
above has IJWn checked.
gone No.:
ate: /�4=
is only to he used when the box for conditional approval in III. B
I (we) certify that I (we) have committed to establish the cropping system as specified in my (our) waste
utilization plan, and if appropriate to establish the interim crop for erosion control, and will submit to
DEM a verification of completion from a Technical Specialist within 15 calendar days following the date
speciif:ed in the conditional certification. I (we) realize that failure to submit this verification is a
violation of the waste management plan and will subject me (us) to an enforcement action from DEM
Name of Land
Signatu
Date: /a-116
Name of Manager(if different from owner):
Signature: Date:
C) Runoff Controls -from Exterior L is (RC)
Faclitv with exterior lots
Methods to tninirnize the run off of pollutants from lounging and heavy use areas have been
installed as specified in the plan.
For facilities without exterior lots, no certification is necessary.
Name of Technical Specialist (Please Print):
Affiliation:
Address (Agency): Phone No.:
Signature: Date:
AWC - April 24, 1996 4

D) Annli i FguipMent Incgllation (WUP or I'
Check the appropriate block
❑ Animal waste application and hand:inz equipmen: specified in the plan is on site and ready
for use; calibration and adjustment materials have been provided to the owners and are
contained as part of the plan.
❑ Animal waste applicadon and handling equipment specified in the plan has not been
installed but the owner has proposed Ieasing or third parry application and has provided a
signed contract; equipment specified in the contract agrees with the requirements of the
plan; required buffers can be maintained; calibration and adjustment guidance have been
provided to the owners and are contained as part of the plan.
9' Conditional approval nimal waste -application and handling equipment specified in the
plan has been purchased and will be on site and installed by - / - 9
(month/day/year); there is adequate storage to hold the waste until the equipment is installed
and until the waste can be land applied in accordance with the cropping system contained
in the plan; and calibration and adjustment guidance have been provided to the owners and
are contained as pan of the plan.
Name of Technical Specialist (Please Print): _ ��A t rut/ • l) r ,4;son
Affiliation:_�ow�l�clr�L�-,Qn L�rvc
Address gen Phone No.:Q�3
Signature. Dater
The foilo signature block is'only to be used when the box for conditional approval in M D
above has been checked.
I (we) certify that I (we) have committed to purchase the animal waste application and handling
equipment as svec-led in my (our) waste management plan and will submit to DEM a verification of
deliver J a.rd installation from a Technical Specialist within 15 calendar days following the date specified
in the conditional certification. I (we) realize that failure to submit this verification is a violation of the
waste imanagement plan and will subject me (us) to an enforcement action from DEM.
Name of Land
Signatu
er :
*//S
Date:
Name of Manager(if different from owner):
Signature: Date:
Please return the completed form to the Division of Environmental Management at the
following address:
Department of Environment, Health, and Natural Resources
Division Of Environmental Management
Water Quality Section, Compliance Group
P.O. Box 29=35
Raleigh, NC 27626-0535
Please also remember to submit a copy of this form along with the complete Animal Waste
Management Plan to the local Soil and eater Conservation District Office and to keep a copy in
your files with your Animal Waste Management Plan.
AWC -- April 24, 1996

NUTRIENT MANAGEMENT PLAN
Grower(s):
Farm Name:
County:
Production Unit:
No. of Animal Units:
Type of Waste Facility:
Temporary Storage Period:
Animal Unit Equiv. Live Wt:
Lbs/Animal Unit /Year.
Lbs of Plant Avail. N:
Brown's of Carolina. Inc
Farm 92
G64D:,J
Finsihing
8000
Anaerobic Lagoon
180 days
135
2.3
18400
This waste utilization plan is based on the following fields, soil types, and crops. If this
information should change, please contact the Soil Conservation Service or Brown's of
Carolina , Inc. so that a new plan can be written.
Tract
#
Soil
Crop
Yield/Ac
Acres j lbs N
Time to
Teld
Type
Code
��/uniC
Required
Apply
1498
1
WaB
B
4.7
50
6.60
1551
Mar -Oct
1498
2
WaB
B
4.7
50
17.00
3995
Mar -Oct
1498
3
WaB
B
4.7
50
9.00
2115
Mar -Oct
1498
3
GoB
B
5.5
50
9.00
2475
Mar -Oct
1498
4
WaB
B
4.7
50
150
822.5
Mar -Oct
1419
1
NoA
B
5.2
50
10.20
2652
Mar -Oct
1420
1
GoB
B
5.5
50
2.50
687.5
Mar -Oct
1420
1
WaB
B
4.7
50
4.50
1057.5
Mar -Oct,
1420
2
GoA
B
5.5
50
3.40
935
Mar -Oct
1498
1
WaB
K
75
6.60
495
S-April
1498
2
WaB
K
75
17.00
1275
S-April
1498
3
WaB
K
75
9.00
675
S-April
1498
3
GoB
K
75
9.00
675
S-April
1498
4
WaB
K
75
3.50
262.5
S-April
1419
1
NoA
K
75
10.20
765
S-April
1420
1
GoB
K
75
2.50
187.5
S-April
1420
1
WaB
K
75
4.50
337.5
S-April
1420
2
GoA
K
75
3.40
255
S-April
----------------------------------------
Total
65.7
21218
Available N
18400
*Difference
-2818

(1.6 lb N/bu)
--,,,Jda Grazed (50 lbs N/ton)
srmuda Hay (50 lbs N/ton)
.;om Grain 0.25 lbs N/bu)
Corn Silage (12 lbs N/ton)
Cotton (0.12 lbs NAbs lint)
G. Fescue Grazed (50 lbs N/ton)
H. Fescue Hay (50 Ibs N/ton)
1. Oats (1.3 lbs N/bu)
J. Rye (2.4 lbs N/bu)
K. Sm. Grain Grazed (100 lbs N/ac)
L. Sm. Grain Hay (133 Ibs N/ac)
M. Grain Sorghum (2.5 lbs N/cwt)
N. Wheat (2.4 lbs N/bu)
i A negative number reflects the total number of lbs of additional N needed to achieve
yields on acreage shown in chart. A positive number.means additional land is required
to utilize the N produced by the animals.
This nutrient management plan has been specifically developed for this swine operation.
The plan is based on the soil types, crops to be grown, and method of applicdation for
this particular operation. The waste must be land applied at a specified rate to prevent
pollution of surface and/or ground water. The plant nutrients in the animal waste should
be used to reduce the ammount of commercial fertilizer required for the crops where the
waste is to be applied. This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle and annual soil tests are
encouraged so that all plant nutrients can be balanced for realistic yields of the crop to
be grown.
Several factors are important in implementing this nutrient management plan in order to
maximize the fertilizer value of the waste and to ensure that it is applied in an environment-
ally safe manner. Always apply waste based on the needs of the crop to be grown and the
nutrient content of the waste. Do not apply more nitrogen than the crop can utilize. Soil
types are important as they have different infiltration rates and leaching potential. Waste
shall not be applied to land eroding at greater than five tons per acre per year. Do not
apply waste on saturated soils or on to land when the surface is frozen. Either of these
conditions may result in runoff to surface waters. Wind conditions should also be
considered to avoid drift and downwind odor problems. To maximize the value of
nutrients for crop production and to reduce the potential for pollution, the waste should
be applied to a growing crop or not more than 30 days prior to planting. Soil incorporation
of waste will conserve nutrients and reduce odor problems.
The acres needed to apply the animal waste is based on typical nutrient content for this
type of facility. Annual acreage requirements may be more or less depending upon the
waste analysis report for your waste management facility.
Additional Comments:

Prepared by:
Title:
Concurred in t
Date: / '--T/ -1G
Date: I'
I understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This
equipment must be available at the appropriate pumping time such that no discharge
occurs from the lagoon in a 25-year 1-day storm event. I also certify that the waste
will be applied on the land according to this plan at the appropriate times and at rates
which produce no runoff. /?
Date: k-9G
Date: - % 1p

V40'� 9z
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
Irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
The following is provided as a guide for establishing application rates and amounts.
Tract
Field
Soil
Type
Crop
Application Rate
in/hr'
Application Amount
* inches
1498
1
WaB
0.60
!
j 1.00
1498
2
WaB
0.60
1.00
1498
3
WaB
0.60
1.00
1498
3
GbA
0.50
1.50
1498
4
WaB
0.60
I 1.00
1419
1
NoA
0.50
i 1.50
1420
1
GbA
0.50
i 1.50
1420
1
WaB
0.60
1.00
1420
2
GbA
0.50
1.50
i
*This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
- Page: 1

NRCS WASTE UTILIZATION
PLAN SPECIFICATIOINS
1. Animal waste shall not reach surface waters of the state by runoff: drib, tnatunade conveyances, direct application, or
direct discharge during operation or land application. Any discharge of waste which reaches surface water is
prohibits
2. There must be documentation in the design folder that the producer either owns or has a notarized agreement for use
of adequate laad on which to properly apply the waste. If the producer does not own adequate land to properly
dispose of waste, he/she shall provide a copy of a notarized agreement with a landowner who is within a reasonable
proximity, allowing him/her the use of the land for waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when there is a change in the operaiton, increase in the
number of animals, method of utilization, or available land.
3. A iLnal was•G. shall be applied to meet, but not exceed, the Nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climate conditions, and level of niatlagenient, unless there are re¢ulations that
restrict the rate of application for other nutrients. Actual vields rrlav be t.lse[l in lieu Of realistic yield tables at the
discretion of the planner.
4. Ani.-nal waste shall be applied on Iand eroding less than 5 tons per acre per sear. Waste may be applied to ]and that
is eroding at more than 5 tons but Iess than 10 tons per acres per year providing ttra_s filter strips are installed where
runoff leaves the field. (See FOTG Standard 393-Filter Saps)
5. Odors can be reduced by injecting the waste or disking a:-=er wait-. apphcaticm. WaJie should not be applied when
there is danger of drib Zorn. the irrigation field.
6. When an.irnal waste is to be applied on acres subject to flooding, it will be aril incorporated on conventionaIIy tilled
cropland. Vven applied to conservation tilled crops or grassland. Elie'xaste may be broadcast provided the
application does not occure during a season prone to flooding. (See "Wileath tr and Ciililare in Noah Carolina" for
guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil iruiitration rate such Ehat ru-nor does not occure off --site
or to .7u7face waters and in a method which does not cause drltt tl't1111 the :Ir,2 dL1r1I1_ appiicalintl. No ponding should
occur in order to control odor and flies.
8. A.aimaI waste shall not be applied to saturated soils, during rainfall C1'Ci1[>, ter Whetl the sulyac: is Frozen.
9. Anirnal waste should be applied on actively growl,-1Q crops in such a nlawier that the crop is not covered with waste
to depth that would prohibit growth. The potential for salE Lainage firt,in animal ivz:rr should also be considered.
10. Waste nutrie is shalI not be applied in fall or winter for sprtng plazired crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should he held to a minirttunl and a suitable %Winter cover crop
planted to take up released nutrients. Waste shall not be applied nwr• than 'sip days prior to planting of a crop or
forazes brew itlg dormancy_
11, Any new svine facility sited on or after. Octobe- 1, 1995 shall cc,tzipiv with the folluwir c: The outer perimeter of
the la. -id area onto which waste is applied frorn a lagoon thar is a C0111 onet of a Z uwine :'_rt shall be at least 30 feet
from any residential property boundary and from any pere:ulial streatti or river t)(her than an it i¢ation ditch or
canal. Animal waste other than sA-ine waste frogs facilitie, sited on or afrer October 1. 1995, shall not be applied
closer than 25 feet to surface water. This dist-mce may be rtdticrd fur Wat.r:. that are:10t pere:lnial provided
adequate vegetative fi ter strips are present (See Standard 393 - Filar -strips).

NRCS WASTE UTILIZATION
PLAN SPECIFICATIONS
(CONTINUED)
12. Animal waste sball not be applied closer than I00 feet from well:.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those oticzied by Iandowner.
I4. Waste shall be applied in a manner not to reach other propery and public tight -of ways.
I S. Animal waste shall not be discharged into surface waters, drainageways or wetlands by a discharge or by over-
spraving. Animal waste may be applied to prior converted cropland provided it has been approved as a Iand
applications site by a "technical specialist". Animal waste applied on grassed waternvays shall be at agronomic rates
and in a manner that causes no runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities, shoxvers, toilets. sitiks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be established 011 all disturbed areas (lagoon e.-nbarlkments,
borers, pipe runs, etc.). Mess shall be fenced, as necessar:v, to IVutect the vegetation. Vegetation such as trees,
shrubs, and ot<'aer woody species, etc. are limited to areas where core-sidtred appropriate. Lagoon areas should be
kept mowed and accessible. Lagoon berms az d sti-uctures shOUILl he inspertc;G re2ulal'Iv for evidence of erosion,
leakage, or discharge.
18. If arin, aI production at the facility is terminated, the owner is responsible ;'car obtaining and inplc:nenting a "closure
plan" wllieh will eLm1nate the possibility of ar: illegal discharge, peilltuiou and cn=sion.
19. Waste handlir:e structures, piping, pumps, reels, etc., should be inapeCted cm a regular basis to prcve:It breakdowns,
leaks, and spills. A regular maintenance checklist should be kept on si1c.
20. Ari.mal waste can be used in a rotation that i,-icludes vegctalbles and crthCr tiru},s or direct human consumption.
However, if &-dmal waste is used on crops for direct human Constlulprioll it slims l only be applied preplan[ with no
further applications of animal waste during the crop seascm.
21. Highly visible pernanenet mark--: s shall be i.-nstalled to marl: the top and borwin elevations of the temporary storage
(ptc.-nping volume) of all waste treatz;Ient lagoons. Pumping shall be managed to inaiiitain the liquid level between
the marker's. A mark.- will be required to rn rk the na.�iliuirti sicn-aPc vDiL1111C tier waste storage ponds.
22. Soil tests shall be made every year, and a liquid %vast.- analysis shall be take,[ within 60 days of application
corsiste;ii uiul waste utilization plan. Poultry liner shall [+e tested prier icy ;ijilificarion. Soil and waste analysis
records shall be kept for five years.
Dead animals will be disposed of in a manlier that Meets Ni C rc�,allatiuns.

EMERGENCY ACTION PLAN
PHONE NUMBERS
DWQ _ho gf q96 Isyl
EtifERGEi�'CY i\,L��AGEhIENF SYSTEM 911
SWCD Sid �s�Z(a93�
Nr,D
,CS 910 c-66,z &M 3!o
=This plan will be irnple..zented in the event that wastes from your operation are Ieak3rg,
overflowing, or running off site. You should not wait until wastes reach surface waters or leave
your prope, zy to consider that you have a problem. You should make every effort to ensure that
this does not happen_ This plan 5bQuld b osted in a acresjble LQcatia-n for aTe=toyg a_ t the
figlitly- The following are some action items you should take.
1. Stop Lie release of wastes. Depending on the situation, this may or may not be possible.
Suggested responses to some possible problems are listed below.
A Lagoon overflow —possible solutions are:
a, Add soil to be,: n to increase elevation of darn.
b. Pump waste to fields at an acceptable rate.
c. Stop all flows to the lagoon irmmediately.
d. Call a purnpL-ig contractor.
e. Make sure no surface water is entern. laccon.
B. Runou corn waste application field -actions include:
a. L, r„ediateiy stop waste application.
b. Create a temporary diversion to contain waste.
C. L-icorporate waste to reduce runoE
d. Evaluate and eluninate the reason(s) that caused the runoff
e. Evaluate the application rates for the Fields where runoff occurred.
C. Lezkage from the waste pipes and sprinklers -action include:
a_ Stop recycle pump,
b. Stop ii— igation pump.
c. Close valves to eliminate fumher discharge.
d. Repair a1I Iea_ks prior to rester L;ng pumps.

D. Leakage from flush systems, houses, solid separators -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Nfazke sure no siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
e. Repair all Ieaks prior to restarting pumps.
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed to flowing
leaks -possible action:
a. Dig a small well or ditch to catch ail seepage, put in a submersible pump, and pump
back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill holes and
compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon bottom as soon
as possible.
2. Assess the: extent of the spill and note any obvious darnaps.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what duration?
c. Any damage noted, such as employee injury, fish kills, or property damage?
d_ Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. CouId a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or of, of the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. DuringrjOr7nal business hours, tali your DWQ (Division of Water Quality) regional office,
Phone 0 After hours, emergency number: d9 733 31,f Your phone call
s.-iould include: your name, facility, telephone number, the details of the incident from item
2 above, the exact Iocation of the facility, the location or direction of movement of the spill,
weather and wind conditions. The corrective measures that have been under taken, and the
seriousness of the situation.
b. If spill leaves property or enters surface waters, call local ENL IS Phone number 911.
c. Instruct EMS to contact local Health Deparment.
d. Contact CES, phone number 210 Flel 401 , local SWCD office phone number
IM SG 2.04 and local NRCS office for advice technical assistance phone number
10 S6a2. &9 ab
4. If none of the above works, tail 911 or the Sheriff's Department and explain your problem to
them and ask that person to contact the proper agencies for you.

5. Contact the contractor ofyour choice to begin repair of problem to minimize off -site damage.
a. Contractors Name:
b. Contractors Address:
c. Contractors Phone: -1691ozv
5. Contact the technical specialist who certined the lagoon (NRCS, Consulting Engineer, etc.)
a. Name:
b. Phone:
7. Implement procedures as advised by DWQ and technical assistance agencies to rectify the
damage, repair the system and reassess the waste management plan to keep problems with
release of wastes from happening again.

Nlortalily M"111"J"ClUcill NIC11106S
(check Which mcthod(s) arc bciw! implemented)
D Burial thrce feet beneath tilt surface of tic ijound within -1 !lours after
know1cdcr of the death. The burial must be ,1t Ica;t 300 feet from anv flocvins'
stream or public body of water.
RcndcrinE at a rcndcriag plant license:! undo. G.S. 106-163.7
Q Complete ufcinc.ation
0 In the case of dead poultry only. piacin�� ill a dlsl705an
1 pit of a si2c alld'dcsi
approved by the Dcpartmcnt of kuiculturc
71 Anv method which in the professional opinion of the Statc Vctc:rinarian would
make possible the salvage of part of a dcad animal's value wililout cndaw-'e-111;,
human or animal hcallh. (wriucn approval of the Staic Vctc:irlarian must bc
attached)
hisect Control Checklist foi* Animal Operations
Suul're Cuusc 11A911S Ill Glnlrl►I Inscels Silc Specific Vraoiccs
Liquid Syslculs _.._.
Flmh G1111crs ALk:1n11Ul:lli011 Ofsulids _ ❑ Flustl syslem is desi1pul and operalcd
suflicicnlly to reunnVe ;Icculnul;llccl sulills from
1;IIIte1','aS dcSlt;lled.
Ci ltcnlove bridging ofaccnnull,llccl solids ill
disrlrn•1;c:
1.:1L11un: clrul Pas Crusl► d Solids M:1i111lin 1:1goous, scnliol; basirls :11111 Mils %vllcrs
I1est tlrc:edint; k a1111are111 to nliniulixe Ille
crusling of solids lu it d1:11111 o llo Illol'e 111;111 CI -
lt inches over more Ilan 30% of snrface.
�l:aeessive vegoalive Decllyint; veLLlalion � Mailltaill vegetative coulrol alone 11;1111s (;I*
t ilu�clll hgoons and nlher imlu,undmcnis lu 1lrcve111
accllmulalion ofllc;cclying vel;ctalive nlaticr
A0111; MINI% edge: on inlIM111lclnlcnl's perilncic:r.

Swine Farm Waste Management Odor Control Checklist
i�rr _._ _ _. *__._.—.-_ ._.. ...�..... ....—�.�-...a....�� — q�aaW �r�:�tt-C:f�ra �T :-a-T SY��—.�cila=.=1_� _—___. __��.. ._.. .. ... ..... ._•--�a�it«...���;� .. ..�..t�._ ..1... .. �..
$uul'cc Cause ItA'li's I() i1'iinirlllx.c 01101' tiilu Slaccific I'a arliL .es
l tlrinslc�rll Swine ploduclioll vcuelillive or wooded bill, cls;
ficcomillelldcd It1:st nlau:al;cnleul practices;
Good judgluclll .Ind cntnolon scllse
Auiulai bully surGlces 0 Nily manrrc-covered mim als r, Dry Moors
(�1lalar ;tu I',,ccs
• wel rllanure-covered !lours V, Sloped Iluurs;
P walertas localcri over sloped floors;
❑ Fecdcrs it Ililgh curl orsuiid floors;
f°..�` Scrape Immure ure buildup morn floors;
Cl Underfloor ventilation for dryinl;
l\I,I1rI11C cullecuoll pill • !trine; Frequent nwoure removal 1r), flush, fail tccharge,
• I'MIi-11 olicrobi:d decoulposilioll orscrapa:;
n lhulerlloor ventilation
ve111a11111111a C.0 all]l falls • volillllt; Biases; Fall tll;linlemillue;
I)IISI ' lirlicicnl air uloverticlll
lnduur sill faces 6 I)Ilsl washdown bowccn groups orllnirmds;
17 Iced adrlilives;
n feeder crtvers;
Filed rlclivcly dutvrlslu►ul crlcnlers to Iccdcl'
Coveys
l:illsla lonks ACilalion orrccycled lagoon 0 11trsb lank covers; - - -- — -
liquid while tzmks ,arc filling 0 lixlend fill lines to near bullonl nrlanl.s wilb
anti•sillhon vcnls
l:I11s11 alleps Agil:alion during wasluwaler rl tlnderlioor flatsh with amlh;rllotir vcnlilalirul
eurlvcynncc
!'il accb�ul;t: puinls Al;ilaliou orra:cytll:d la(sntra I:xlco4l rctaa:n'Lc lines (ll nc,u•lautl,nal ul'laits _�
lirluid while pHs are filling with ;ulti-siplll►n venls
f.il't slali,nrs - - - - Agilatioo {hlrinG srtnlp lank
filling anll drawdown
Oulsidc drain I ollc cliull AZHation IlurilIg wastew-tler
ur)lmction boxcs conveyallce
rl tianala talk covers
f:l Ilox I avers
ANVIL - 1•lovlmber 11, 1996, l'Iagu 3

Saurcc Curlse IIMI's to A inimiee 011o►' - Site specific Prlcfices
End of drainpipes al • Agifation during ►vaslewaler I?xlcild discharge point of lilies urlderncalll
lagoon conveyance lagoon liyllid level
lagoon surfaces • Volalile gas cmissions; Proper lagoon liquid capacity;
• Biological mixing; Colrccl lagoon slartup procedures;
* Agitation ] Mmiomm surface area -la -volume ruio;
`1 Minimum agilalion ►vllcn.pilltyillg;
f-I Mechanical aeralion;
f.1 Proven Biological addilives
IIIigauiorl sprink. ier 0 high pressure agilalion; l igale on dry clays Willi little or tin %villtl;
OULICS • wind drift '
P Minirinnll rccolnnicluled operating pressure;
f�f Pump mlake near lagoon licpiid surfing;
Cl I11111I1) front second-51age Lagoon
Slur;il;e lack or b;isiu 0Partial iuicrollial Ilecompushion; n I lollom or nu{Ilcvel loading;
SIII1•"Le • Mixing while filling;
Cl '!'atlk covers;
• Agitation when emptying C1 Basta surface orals of solids;
Cl
Proven biological addilives or oxid;uils
sculilig basill surface 0
Parlial nliCnlbiul dcconlpnxition;
Cl
lixtend dr;Iinpipc otllicls urldcricalll liquid
•
Mixing while' filling;
level;
•
Agitation when emptying
Cl
Rcinovc sculed Solids regulal ly
Mmuire, slorry ur sludge •
Agilalimi wlicti spreading;
C1
Soil injeclimi ol'slitrry/shulges;
splceller mullets 0
Voialile gas culissiolls
f7
WaSh'residual III;1111ll'c from spreader aflcr use;
Cl
Pl,oven biological addilives or oxillaws
Ilncovcrcd inanorl:, 6
Volwile gas crnissiolls while
f-1
Soil injection ofshury/slollgcs
slorry orsli,lgc on field
dlyiog
r)
Soil incorporation %vidliu'lli fins.;
sui I;rccs
,
C)
Spread in thin imifarm Dryers fur rapid drying;
n
Proven biological iulllilivc5 or oXi{Lulls
OL:all allimals 0
�l)ead
Carcass decoluposilitil
11roperdislosiliori ofearcasscs--
animal disposal 0
Carcass decomposilioll
Cl
Complele coveriig of carcasses III burial pill; Y
ails
C1
Proper localionlconsiroution o!'ilisposal pits
�lII[Iller;ilia, •
Incullillicle Cllnlbllstilrn
Cl
Sccolld.lry stack blll'llers
Ah•JOC - t`luvcmber 11, 1996. Page 4

Stilrrcc Cnllse lIA1I's (n 1NIIIUllize 011111. S1t►; �pccific Pra[ ices
Slanding wall ;r1•uurld • Improper drainage; Gradc and landscape such that ►valcr 411:611's T..�
I;Icilirics Microbial dccompusilimi or away Goal I;lcilides
orga11ic miller
Alauurc Irackell onlo • Poorly maintained access roads Darin access road mainienuncc
Imblic r+lads glom farm
access
Addilimml Information : Availahlc From
Swine Mauurc MaaaGumum ; 0200 ItuldUMP 1lack—d NC.';( I, Comity lislcusion Cciocr
Swine Prulluclion Farm 1113lealial Odor Sources and ltemcclics ; I:l3AL filet. Sheet NCStI - IIA H.
Swint: Produclion facility Mallurl; Managemcm: Pit Iteclparge - Lagoon Trcalmem ; 1i13A1: 12E1-911 NCSI I - 13A F
Swine Prodnclioll F.1cilify Manure Managcillcnl: Uuderl3our Flush - 1 ogoon Tucalment ; I'IJAF 129-Ii11 NCSI I - I I A I:
I.agooll i)esil;a and Mmiagemcat liar Livcsloek Manure Treatnlcili aacl Slur;ll;c ; 1;13AE. 1113-113 HC'SI I - I IA I:
C,1lihratimi nr Mannrl: ami mislcwaler Applicatimi L(juilimcnt ; IiItAI: Fact Shuct WWI I - I lA li
Cularcllinl; Odors rlaol Swine Buildings ; P111-33 NC5A I - Swioc 1:'xicasitm
Fuviromucmal Assmancc Program ; NIIPC Manual NC I'm k I'ru11ucers Assoc
Oplians rur Managing Odor; a repxt from 111c Swiuc Odor'Tnsk I-orcc: NCSI l Agri [:ommilnicarinns
Mrlisancl; Comcclns in Aaimal MalIrc MaI)ages IIClil: Odors and Flies; IIIto 1(17, 1995 CullfercncC ProccelIis)gs Florida Coollcralive Exlensirnl
AM( Ir: - November 11. 1996, Parc 5

• �".'s yew-.:.ram"'v-tii-
+; AuA A
JO o Oc tt?'�`.., y ��i� �►t{ ' s rheet
a.
�:r `. �_ _�.- F,to 3.: Fo31b"" B • r:: "r- R = ,p 'NoA � • �k' .�wYy _ r _ . � •
a : • ,�.`, 1` -_" NoP J ,. � � c s a. _ O ., ti, �:- •,. c'
GtiA Tom,_ _. "�:, GhA �,� _, •_ r.G •Wa'B -L ^ oP t' "dL• '7:� p Gv
Ra y1 Y` NoA'
`� Was
•'i.8- c �`. Oc o' �;,,�t` ;. ° �D P-, 'Y � F,Oc �� Oc �-rl..�,}.- �`K .,-, � 'M• �r
�o AuA
.:p
GbA o pUA :7r WaB : p DuA . y �.
t3t3 N°RWg
' LaB -,rk Oc NoA
NIA.
r Tcri
Rj
'wA ,Rai : b _ :? ' ` ` ".: }' oA -•' °q R t -+° Oa
�. 1, a a '
AuA GbAr Ra 4 r�ae
1 n ti° Pq; r _ r, �, LT, V�
Nu
AuA
!O F;e #, AuA `cA Ilk-
pq
.•f � Ra u Foa
/r Ln
NoA
NJ
Oc Ra
Gum. Flat 9 Au,ILr. Ra NoA
AuA Fo Bab, ?\ Wo`
Ce ,A v3y# _� p °4 No, +
J S uA -tom s" P B
W t ,Wo r,. - uA 7-
0 c
40
j: Oc :, .: puA •:?:iSsi 4? SuA' F�
AuA
GbA c S_ t Q4q ,� f F .
iLe,
e . F375
Ud R Nos Zf . 1 �t5' � ti ti AteA ;r
J. � �;� . Tr , � • � , ,,: _ ,;_ ,sir _ .� ,,�� �ot.
FOU4 L7j Ru c AuA 3100•. '•.� !y %ta:f};-BUA Fo
a ' Vyr
JpQ c aA. u�
GbAOc
- rAu1Y r
-WHB , ., ,� of = .1, - - •6 - a'-y -
:! Wa6=W881
r t d S AuA �R *p; q •qJ y�at�.,
Was
r 3 -r -• - CCa :. f - p
Nod
WKS
Oc �aq, �- r Y NoAloRf.
s
AuA ` Wa8 W 6B °1 P
30
�:i ; fit` f' 3i, -•K • T OO Ce
I � t Tl�
p 47 v
m -� ° �•. : ' -' w"".- ,a'� �' /t AuA
�, � � =A•� r'E� , „�, }yrTi��s - - y' t �f Jr WO` 1� _ BOG
- �:,�+a•^�`s ry� L 1 1 r -Y���. t'•-T X2 ..
Waste _ - -� wD ,OP
B
Oc W - _ ' _ G .
wa Ce C�
WSB r O
v
e

- 4� a r J� r 1 r �.'s• y � Yr
t}'r 4�J,¢r !r!r'Cw_�t��i� t Fw,fy?!j' }r�•5` d ��'�, r _ .i��r r�fxd ;
�,�}� .�3 �' .r.'•.'�.i:.r fr r Jr'4 � , tyr f �yf { x s
r1� �. f c. - _ rliC +� ;; '��� \- rvi� 1L_ jf 41•.ly. � �p ��$S # J'� �i �'
4+ {rt•* 1 r d' s ?� ; � 'f;�'+ irr }'d ri a r(�. p S � -ir,
r- i i 'I�• r1_f x, rq�v?}�I. t..� ��L`'ir.
r li�ylsCtr�3 I L'{ L•T.�Frj: �rN.�RrlAx
•r •k a • f ,•� ..+5� 1r Cy. L ";11�I' .,7•.�;��rJri:iy
�7LW" Ts L ri i
' �.,,I r 1 ��'„� �1.Li, 7 � � ✓ Lit. �.,�h 1..it.,�.,, ����1
1SZy9t.PIy ;+ (F`rf etfw�,�T,tr
',[�y[, a SI A..t Itf. F.�'$T4i :,y51J�� rY,.! }k,y r r '• T P15M, ' r'•
S � • }tii Y��y�1 LLLLRrrrr'r�r�r Nl ; ��+��•1•{4��i �M f.Y6 rS: t1., t }F �P i��r.
"�`'FTr� f.1•;> L,, � +: ra ,a {r� f1�6 �: ?' ti-t; `i Y� �i "tjr4'S ��� \id4alr `,�' ��yy
ti�➢ql�r< ?+'�,4 ! ➢' fl r y +' 'vh � �' r f t}] i.,•• ' r�t �.jt��•7 •,
j:��'�, r�`',• ,,.7t,d�+" rr r r Lr i1, . 4 � i ��`,�'+� �%tif; � ,4 rq a rMr• t
pv
Q4 �+ � } ! i }.! f. f Cf •A fi » , s y, r L.r � �: 1.� rt �y� 1� tk��cr t�T 1
h �, #
� �L ��tiV�f1.H a,� } j, r `ad ;� i ?i't ��, � r �:' �L➢ J 6�i�"� ,+�� F � cr e �
YrfY,' �,{ 4i i6r� �� y�r Gy, ° i� a. �-} r h �+ � rA}r �„•� L tr �`. y' (,rr"��)� ,. ,•14! rYrr C �r , N, i.4'Ks-
\ Tlr}}1F.,� ,.� , C} I�,r;,r �1f^f �`�Ri`kC.'•}Tia�'�It � 7 ,7 r�+L.( '1^.•t G' r��,'� � y,{. i,
y., , '^ ,,�,r �•r , fit' ,fir_,\ f° L�}i
Sri' '�-t r 4+too
i +!•,y'rk", 1 �r 4[ �y.rj t
Y�AMU
�r�t�r1�`ry�.�:,,'�• �' "•1�45,'�r' �{"�y r �t�' �'f'?'ii /
C'S�y s�e�5 'R i�°�}7'�ki�r.�112• G � r r4rY� �, �.`irr F�: f�"f �! 3�.- �.- �r{�
!� a�{ y'{„!� -.�.x • � �! +r,"' ' f ' y^f�4 �%Yrr' ' �f sv � i�f �{ r }' } � i
777 i � 71 r r •t' 'h, r
9�i",s ,- �'� A'rE 4` �r�Y ►4r 'A,ti (t 1t�� k,�4c�'+�,�r�i
r/^ � d r '',jF,�j.Lf��yr°r'J aif � p� �•E�,: S'a f r.
4- Y?,�af'y r?_�idra g 4 Y '� r�;t1�►�w°Fi1�i.lf �ti s
-� [ ' }!I!"^"""4, S. L. '�' '��,-# -Lf ''T{rl'N• i rr ,M lN�e -f a fSL• \
{;l� 1rt., L,'a �T ���. y ri�-L..',1�R,i L, t�� x •+trtitti 4t:i
..r '� 1'y R \t � r4 �} rfl i4r �a ��t� A� �a��fj�.,}'�� rz1 �N `�F t �3F tL�l-1'�r�fC °•.
��-� r' d` YF}r'�� l�,y. Lf* � t tf G'kY I lrrltis � L � T -fee !I_ {•
�&ir' �iv� . .,,. �:'�'. �. , r,ti� ➢.r ,t.�J�. . r >c1i '.�lr,{1.1.s. •.nr•,t <.. :f. .r. . 1! .r e�.:'r.'r-;a�E
I :ji�r 'g4��r��i\pr'!"f,'� t,�"•ti'•M^/j'�f'�5�}�'�f)l� 4+'I
'`-f%'"I" fl lr� �t-1 :'Y S\,� t�.�lf'`� h'f .l '�•ii
f�e 7e f
Im
—a Wli"Offl, 4.4

U.S.D.A. _ _ SCS-Cr 026 I. Name and Address at Person 2. Date of Request
Soil Conservation Service 91)
W. Baker bci lson 9 5 95
HIGHLY ERODIBLE LAND AND WETLAND Rt . 2, Box 114 3. County
CONSERVATION DETERMINATION 'far Heel, NC 28392 Bladen
4. Name of USDA Agency or Person Requesting Determination 3- Farm No. and Tract No. .
^ SECTION I - HIGHLY EFIODIIBLE LAND
FIELD NO.(s)
TOTAL ACRES
6. Is soil survey now available for making a highly erodible land determination? Yes ❑ No ❑
=
h
7. Are there highlyerodible soil m units on this farm? Yes ❑ No
map ❑
-.;fix a.sdw
8. List highly erodible fields that, according to ASCS records, were used to pra&ioe'an agricultural commodity in any
crop year during 1981-1985.
9. List highly erodible fields that have been or will be converted for the production of agriarttural commodrdes and,
according to ASCS records, were not used for this purpose in any crop year during i981-1985; and were not
enrolled in a USDA set -aside or diversion program.
10. This Highly Erodible Land determination was completed in the: awe [ Field ❑
.•�.�:.:::.�:: -�'
sax:»; _%:c��
WF�" ,a., ',ems-F:Ti7
FIELD NO.(s)
TOTAL ACRES
11. Are there hydric soils on this farm? Yes © No ❑
.r..,.,._.�_.,.,.
-'. � �=aLL ,
12. Wetlands (W), including abandoned wetlands, or Farmed Wetlands (FW) or Famsed Wetlands Pasture (FWP).
Wetlands may be farmed under natural conditions. Farmed Wetlands and Farmed Wetlands Pasture may be
farmed and maintained in the same manner as they were prior to December 23,1 %5, as long as they are not
W 5
:!
abandoned.
y
—`
13. Prior Converted Cropland (PC). Wetlands that were converted prior to December 23,1985. The use, management,
drainage, and alteration of prior converted cropland (PC) are not subject to the wetland conservation provisions uritess
the area reverts to wetland as a result of abandonment.
14. Artificial Wetlands (AW). Artificial wetlands includes irdigalion-induced wetlands. These wetlands are not subject
to the wetland conservation provisions-
15. Minimal Effect Wetlands (MM. These wetlands are to be farmed aacordumg to the minirai-effect agreement signed
at the time the minimal -effect determination was made.
16. Mitigation Wetlands (MIW). Wetlands on which a person is actively nmitigabrmg a frequently cropped area or a wetland
converted between December 23, 1985 and November 28, 1990.
17. Restoration with Violation (RVW-year). A restored wetland that was in violation as a result of conversion after
November 28, 1990, or the planting of an agricultural commodity or forage prop_
18. Restoration without Violation (RSVP). A restored wetland converted between December 23, ISM and
November 28, 1990, on which an agricultural commodity has not been planted_
19. Replacement Wetlands (RPW). Wetlands which are converted for purposes other than to increase production,
where the wetland values are being replaced at a second site.
20. Good Faith Wetlands (GFW+year). Wetlands on which ASCS has detenruned a violation to be in good faith and the
wetland has been restored.
21. Converted Wetlands (CW). Wetlands Converted after December 23, 1985 and prior to Novenmber28.1990. In any
year that an agricultural commodity is planted on these Converted Wetlands, you wig be ineligible for USDA benefits.
22 Converted Wetland (CW+year). Wetlands converted after November 28, 1990_ You will be ineligible for USDA
program benefits until this wetland is restored.
23- Converted Wetland Non -Agricultural use (CWNA). Wetlands that are converted for trees, fish production, shrubs,
cranberries, vineyards or building and road construction.
24. Converted Welland Technical Error (CWTE). Wetlands that were converted as a result of inoorrect deternation
by SCS.
25. The planned alteration measures on wetlands in fields are considered maintenance and are in compliance
with FSA.
26. The planned alteration measures on wetlands in fields are not considered to be maintenance and it
installed will cause the area to become a Converted Wetland (CW). See item 22 for 4*mw -A&m on CW+year.
27. The wetland determination was completed in the office 1p field F1 and was delivered[] to the person on K -
28. Remarks. "I
29. 1 terrify that the above determination is correct and adequare for use in dri-ermirung 30. Signalure of SCS Dist is Conservationist 31. Date
eligibility for USDA program benefits. and that werland hydrology, hydric soils. and
bydrophyric vegetation under normal circumstances edst on all areas ondined as
Wetlands Farmed Wetlands and Farmed Wetlands Pasture. -
Assrsrnce and progmnw of the Solt Conservation servk v - EFahls.ro m f ieg.d to rsiM P ft i, tabu, saw, ugm ar hwmdcap:
Copy.

In

Facility Number and Name: Brown's 9-181, Farm #92 Instructions on last pa
I OF
j —ae,
Pill,;
I. MS.
Wettable Acres
9
Description of Concernt
9/112000 Re'ce'ved letter of noffication of
wettable acre determination
FR
2
Response
MIP�Ps� �L,
EM
- — - x
a-l9-1-- SIMI-offir
2311/01 = Wettable acre determination
completed and certified.
M
�9
Wettable acres 57.34 ac
Y i V7---
E�
MM2

Facility Number and Name: Brown's 9-181, Farm #92
Instructions on last page
ALA
YLKV AMIN
M4
a. -20--W-I
IC U -iIN
PP, ti D
M
!x
W.--mvIssues 1'.
-T
Cropping Issues
Description of Concern
gp� m nip-
47
N f IY! 2 z WN -M
�MZ
-_IMWPf,4 4
m
M RON
p-g �n-wz- ED
M
6/20/97 ORCAR Spray coastal
with 2-413, Nitrogen @ 75lbs/acre.
$-a A
_8
wm-,
0,
M"Er
M
;Z-
E3
NRCS allows 50 lbs/ac
INSPECTIONS
Spray for weeds
'S,
MEN-
8/8/UU - Spray for weeds
M
Response
015.20
-7
w ON
,igg Mv -4
—g M
§rg
1-U1
ail M�- F,
N M - '.Y
Weed control program now in
place.
i�M M
M=Ms wigo-
gn, 4in
im
m
ONE
M,
_y:7 -f-M
NOME
PI MIR
wml
I: Mr
ivLq c.
T,IOIW
M Mm�F
I ; N
-M
a
X-Ow
-ktpp
F
R.
A F
VI_-- �S 4 W- -a M -1-04
E
I

1 Concerns are based upon DWQ records consisting of deficiencies noted in state inspection reports, NOVs, penalty assessments and/or reports submitted to DWQ by the farm. Carefully
review your records to identify the specific concem or concerns and then describe the concern under the appropriate heading together with a reference to the specific record and the date of
the record (i.e., inspection report dated or NOV dated �. With the exception of "discharges," which cover calendar year 2000, concerns are based on DWQ records for the
calendar years beginning January 1, 1996, and ending December 31, 2000.
` Describe in as much detail as possible how the concern has been addressed, or, if it has not been addressed, the measures the farm intends to undertake to address the concern and a
schedule for completing the measures.
3 1f subsurface drains are present, state whether you know that the drain(s) is discharging groundwater uncontaminated by hog waste, and if so, the basis for that conclusion.

Facility Number and Name: Brown's 9-181, Farm #92
Description of Concern
Instructions on last pie
Wettable Acres
9/l/2000 = Received letter of notification of
wettable acre determination
311/01 = Wettable acre determination
completed and certified.
Wettable acres = 57.34 ac

Facility Number and Name: Brown's 9-181, Farm #92 _
Instructions on last page
>'Mrx-.
zON
�- _- .'r-sT_
sr -'-•u - _,_ xp .•
f
-
a
SubsurfaceDrains3
r licaton=S#ructural
sues
CroppingIssues
_U ev A _
Description of Concern
6/20197 = ORCAR —Spray coastal
with 2-4D, Nitrogen @ 7Mbs/acre.
xc
Z
P
�x _ .i'
_
NRCS allows SO lbs/ac
INSPECTIONS
w
—Spray for weeds
8/8/00 — Spray for weeds
Response
control program now in
ace
`
z
"
'
'•=s
.. - "-tea , _
a �__ �,.
_
-
-,
k�

1 Concerns are based upon DWQ records consisting of deficiencies noted in state inspection reports, NOVs, penalty assessments and/or reports submitted to DWQ by the farm. Carefully
review your records to identify the specific concern or concerns and then describe the concern under the appropriate heading together with a reference to the specific record and the date of
the record (i.e., inspection report dated or NOV dated ). With the exception of "discharges," which cover calendar year 2000, concerns are based on DWQ records for the
calendar years beginning January 1, 1996, and ending December 31, 2000.
z Describe in as much detail as possible how the concern has been addressed, or, if it has not been addressed, the measures the farm intends to undertake to address the concern and a
schedule for completing the measures.
3 If subsurface drains are present, state whether you know that the drain(s) is discharging groundwater uncontaminated by hog waste, and if so, the basis for that conclusion.
3

State of North Carolina
Department of Environment, Health and Natural Resources
Division of Water Quality
Non -Discharge Permit Application Form / Survey
(THIS FORM MAY BE PHOTOCOPIED FOR USE AS AN ORIGINAL)
General Permit - Liquid Animal Waste Operations
The following questions have been completed utilizing information on file with the
Division. Please review the information for completeness and make any corrections
which are appropriate. If a question has not been completed by the Division, please
complete as best as possible. Do not leave any question unanswered.
Application Date:
I. REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next.to each
item.
1. One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
2. Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is disposed;
3. Two copies of the Certified Animal Waste Management Plan (CAWMP). If the facility does
not have a CAWMP, one must be completed prior to submittal of a general permit application
for animal waste operations.
II. GENERAL INFORMATION:
L Farm's name: Farm 92
2. Print Land Owner's name:Brown's of C lina G
3. Land Owner's Mailing address: PO Box 487
City: Warsaw NC Zip: 28398
Telephone Number: 0 - 4 2-1 G ( fro- 0
4. County where farm is located: Blade .
5. Farm Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a copy
of a county road map with the location of the farm identified): :Q 3 5
6. Print Farm Manager's name (if different from Land Owner):
7. Le a name (if applicable; please circle which type is listed): Brown's of Carolina T1� C--
OVlJ E!Z
09 - 181
RECEN
JUN 2 5 1991
FAYETTEVILLE
REG. OFFICE
FORM: AWO-G-E 2/26/97 Page I of 3

III. OPERATION INFORMATION:
1. Farm No.: 09-1 i
2. Operation Description: _operation
Feeder to Finish
8000 - Certified Design Capacity
Is the above information correct? W yes; Flno. If no, correct below using the design capacity of the facility
TyW of Swine No. of Animals Tyj2eofPouljjT No.ofAnimals Type of Cattle No- o£Animals
0 Wean to Feeder 0 Layer 0 Dairy
Feeder to Finish If000 0 Non -Layer 0 Beef
0 Farrow to Wean (# sow) 0 Turkey
0 Farrow to Feeder (# sow)
0 Farrow to Finish (# sow)
vtu.'.r +,.TP- of i'� .t. �..iiv..1i: on
3. Acreage cleared and available for application: 66; Required Acreage (as listed in the CAWMP): 6.7
4. Number of Lagoons: l ; Total Capacity: 1091488 Cubic Feet (ft3)
Number of Storage Ponds: D ; Total Capacity: Cubic Feet (ft3)
5. Is animal waste being applied on any field which has subsurface drains? YES or O (please circle one)
6. Are subsurface drains present in the vicinity of or under the lagoon? YES or O (please circle one)
I V . APPLICANT'S C RTIFICATION:
1, `1
..1I't1 0 Cr PO' (Land Owner's name listed in question 1I.2), attest that
this application for S Or— [ _6&LI � . /fy- fiARN� 1 Z (Farm name listed in question H.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be ed to me as incomplete. / ry
Signature Date
V . MA A ER'S RTIFICATION: (complete only if different from the Land Owner)
I, (Manager's name listed in question 1I.6), attest that this
application for _ _ (Farm name listed in question II.1)
has been reviewed by me and is accurate and complete to rate best of rry knowledge. I understand that if a!l required pats of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be returned as incomplete.
Signature
Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
PERMITS AND ENGINEERING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FORM: AWO-G-E 2/26/97 Page 2 of 3

State of North Carolina
Department of Environment, Health and Natural Resources
Division of Water Quality
Non -Discharge Permit Application Form / Survey
(THIS FORM MAY BE PHOTOCOPIED FOR USE AS AN ORIGINAL)
General Permit - Liquid Animal Waste Operations
DIVISION OF WATER QUALITY REGIONAL OFFICES (2197)
Asheville Regional WQ Supervisor
59 Woodfin Place
Asheville, NC 28801
[phone]
Fax [phone]
Avery
Macon
Buncombe
Madison
Burke
McDowell
Caldwell
Mitchell
Cherokee
Polk
Clay
Rutherford
Graham
Swain
Haywood
Transylvania
Henderson
Yancey
Jackson
Fayetteville Regional WQ Supervisor
Wachovia Building, Suite 714
Fayetteville, NC 28301
[phone]
Fax [phone]
Anson
Moore
Bladen
Richmond
Cumberland
Robeson
Harnett
Sampson
Hoke
Scotland
Montgomery
Winston-Salem Regional WQ Supervisor
585 Waughtown Street
Winston-Salem, NC 27107
(910) 7714600
Fax [phone]
Alamance
Rockingham
Alleghany
Randolph
Ashe
Stokes
Caswell
Surry
Davidson
Watauga
Davie
Wilkes
Forsyth
Yadkin
Guilford
Washington Regional WQ Supervisor
943 Washington Square Mall
Washington, NC 27889
[phone]
Fax [phone]
Beaufort Jones
Bettie
Lenoir
Camden
Martin
Chowan
Pamlico
Craven
Pasquotank
Currituck
Perquimans
Dare
Pitt
Gates
Tyrell
Greene
Washington
Hertford
Wayne
Hyde
Mooresville Regional WQ Supervisor
919 North Main Street
Mooresville, NC 28115
[phone]
Fax [phone]
Alexander
Lincoln
Cabarrus
Mecklenburg
Catawba
Rowan
Cleveland
I Stanly
Gaston
Iredell
Union
Raleigh Regional WQ Supervisor
3800 Barrett Dr.
Raleigh, NC 27609
[phone]
Fax [phone]
Chatham
Nash
Durham
Northampton
Edgecombe
orange
Franklin
Person
Granville
Vance
Halifax
Wake
Johnston
Wauen
Lee
Wilson
Wilmington Regional WQ Supervisor
127 Cardinal Drive Extension
Wilmington, NC 28405-3945
[phone]
Fax [phone]
Brunswick New Hanover
Carteret Onslow
Columbus Pender
Duplin
FORM: AWO-G-E 2/97 Page 3 of 3

0� WA Michael F. Easley, Govemor
Q William G. Ross Jr., Secretary
oNorth Carolina Department of Environment and Natural Resources
j r Alan W. Klimek, P. E., Director
Division of Water Quality
April 9, 2003
Brown's of Carolina, Inc.
Farm 92
PO Box 759
Rose Hill NC 28458
Subject: Certificate of Coverage No. NCA209181
Farm 92
Swine Waste Collection, Treatment,
Storage and Application System
Bladen County
Dear Brown's of Carolina, Inc.:
On March 14, 2003, the North Carolina Division of Water Quality (Division) issued an NPDES General
Permit for swine facilities. The General Permit was issued to enable swine facilities in North Carolina to
obtain coverage under a single permit that addresses both State and Federal requirements.
In accordance with your application received on February 13, 2003, we are hereby forwarding to you this
Certificate of Coverage (COC) issued to Brown's of Carolina, Inc., authorizing the operation of the
subject animal waste collection, treatment, storage and land application system in accordance with
NPDES General Permit NCA200000. The issuance of this COC supercedes and terminates your COC
Number AWS090181 to operate under State Non -Discharge Permit AWG100000.
This approval shall consist -of the operation of this system including, but not limited to, the management
of animal waste from the Farm 92, located in BladenCounty, with an animal capacity of no greater than
an annual average of 8000 Feeder to Finish swine and the application to land as specified in the facility's
Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or Farrow to Feeder
operation, there may also be one boar for each 15 sows. Where boars are unneccessary, they may be
replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a rate of 4 gilts
for every 3 sows
The COC shall be effective from the date of issuance until July 1, 2007. Pursuant to this COC, you are
authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully, read this COC and the enclosed General Permit. Since this is a new joint State and
Federal general permit it contains many new requirements in addition to most of the conditions contained
in the current State general permit. Enclosed for your convenience is a package containing the new and
revised forms used for record keeping and reporting. Please nay careful attention to the record keeping
and monitorinfr conditions in this permit. The Devices to Automatically Stop Irrilzatiort Events Form
must be returned to the Division of Water Qualiq no later than 120 days following receipt of the
Certificate of Coverage. The Animal Facility Annual Certification Form must be completed and returned
to the Division of Water Quality by no later than March 1st of each year.
AM
Nzmm—
Non-Discharge Permitting Unit Internet httpJ/h2o.enr.state.nc.us/ndpu
1617 Mail Service Center, Raleigh, NC 276WI617 Telephone [phone] Fax [phone]
Customer Service Center Telephone [phone]
An Equal Opportunity Action Employer 50% recycled/10°.6 post -consumer paper

If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Perminee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Pennittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 2H .0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per MRCS standards a 100 foot separation
shall be'maintained between water supply wells and any lagoon or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C, the Clean Water Act and 40 CFR 122.41 including civil penalties, criminal
penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual NPDES Permit by contacting the staff member listed below for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Sue Homewood at [phone] ext. 502.
Sincerely,
ZdY_
for Alan W. Klimek, P.E.
Enclosures (General Permit NCA200000, Record Keeping and Reporting Package)
cc: (Certificate of Coverage only for all cc's)
Bladen County Health Department
Fayetteville Regional Office, Water Quality Section
Bladen County Soil and Water Conservation District
Perrnit File NCA209181
Permit File AWS090181
NDPU Files

Murphy-Brown,LLC 9/13/02 2822 Hwy 24 West
P.O. Box 856
Warsaw, NC 26398 .
�,- Vb\ NUTRIENT UTILIZATION PLAN
Grower(s):
Farm Name:
Brown's of Carolina
BOC #92
County: Bladen
Farm Capacity:
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish 8000
Storage Structure:
Storage Period:
Application Method:
Anaerobic Lagoon
> 180 days
Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems-
1 of 8
B00119220594

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, W, tons, etc.):
Capacity Type Waste Produced per Animal Total
Farrow to Wean
3212 gal/yr
gaUyr
Farrow to Feeder
4015 gal/yr
gal/yr
Farrow to Finish
10585 gaUyr
gaUyr
Wean to Feeder
223 gaUyr
gal/yr
8000
Feeder to Finish
986 gal/yr
7,888,000 galtyr
Total 7,888,000 gaUyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (ibs):
Capacity Type Nitrogen Produced per Animal Total
Farrow to Wean
5.4 lbstyr
lbs/yr
Farrow to Feeder
6.5 lbs/yr
Ibstyr
Farrow to Finish
26 Ibstyr
lbs/yr
Wean to Feeder
0.48 lbs/yr
lbs/yr
8000
Feeder to Finish
2.3 lbs/yr
18,400 lbs/yr
Total 18,400 Ibstyr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 57.34
Total N Required 1st Year: 18444.00
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops: 18,444.00
Total Nitrogen Produced by Farm: 18,400.00
Nitrogen Balance for Crops: (44.00)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2 of 8 B00119220595

Reception Area Specfffcatfons
Tract Ffeld Irrigated Soil 1st Crop Time to 1st Crop 1st Crop Lbs NlAc Lbs N Total lbs N
Hydrant Acreage TvPe Code AviAv Yield lbs NlUnit Residual IAc Utilized
2nd Crop Time to 2nd Crop end Crop Lbs NlAc Lbs N Total lbs N
Code Apply Yield lbs NlUnit Residual /Ac Utilized
Total
Lbs NlAc
Total lbs N
Utilized
1490
1
2.4
WaB
C
Mar-Aug_5.5
50
275
660,00
L
Se t15-Oct'Feb-Mar
2.0
50
100
240
375
900,00
1498
2A
1.79
WaB
C
Mar -Aug
5.5
50
275
492.25
L
Se 15.Oct;Feb-Mar
2.0
50
100
179
375
671,25
1498
2B
1.42
WaB
C
Mar-A
5,5
50
275
390.50
L
Se t15.Oct Feb -Mar
2.0
50
100
142
375
532,50
1498
3
2.87
WaB
BIC
Mar -Aug
4,8
50
240
688.80
K
Se 15.Oct�Feb-Mar
1.5
50
75
215.25
315
904.05
1498
4
2.73
WaB
BIC
Mar -Aug
4.8
50
240
655.20
K
Se t15-OctFeb-Mar
I'S
50
75
204.75
315
859.95
1420
5
1,99
WaB
C
Mar-Aua
5.5
50
275
547,25
L
Se t15-Oct'Feb-Mar
2.0
50
100
199
375
746.25
1420
6
1,45
WaB
BIC
Mar -Sept
4.8
50
240
348,00
K
Sept -Apr
1.0
50
50
72.5
290
420.50
1498
7
5.31
WaB
BIC
Mar -Sept
4.8
50
240
1274.40
K
Sept -Apr
1.0
50
50
265.5
290
1539.90
1498
8
5.27
WaB
BIC
Mar -Set
4.8
50
240
1264.80
K
Se t-A r
1.0
50
50
263.5
290
1528.30
1498
9
5.55
WaB
BIC
Mar -Sept
4.8
50
240
1332.00
K
Sept -Apr
1.0
50
50
277.5
290
1609,50
1498
10
2.47
WaB
BBC
Mar -Set
4,8
50
240
592.60
K
Se t-A r
1.0
50
50
123.5
290
716.30
1419
11
2.43
NoA
BJC
Mar -Au
5.4
50
267.5
650.03
K
Se t15.Oct'Feb-Mar
1.5
50
75
182.25
342.5
832.28
1419
12
4.61
NoA
BIC
Mar-Aua
1 5.4
50
267.5
1233.18
K
Se tl5-Oct'Feb-Mar
1.5
50
75
345,75
342,5
1578.93
1419
13
5.19
GbA
BIC
Mar-A
5.7
50
285
1479.15
K
Se t15-OctFeb-Mar
1.5
50
75
389.25
360
1568.40
1498
14
5.93
WaB
BIG
Mar -Aug
4.8
50
240
1423.20
K
Se t15-Ocl Feb -Mar
1,5
50
75
444.75
315
1867,95
1498
15
5.93
Was
M
Mar -Aug
4.8
50
240
1423.20
K
Se 15.Oct'Feb-Mar
1.5
50
75
444.75
315
1867.95
Totals: 57.34 14454, 75 2989.25 18444
3(a) of 8 B00119220596

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen_
In interplanted fields ( i_e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized_ Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized / unit yield
A
Barley
1.6 lbs N / bushel
B
Hybrid Bermudagrass - Grazed
50 lbs N / ton
C
Hybrid Bermudagrass - Hay
50 lbs N / ton
D
Corn - Grain
1.25 lbs N / bushel
E
Corn - Silage
12 Ibs N / ton
F
Cotton
0.12 lbs N / lbs lint
G
Fescue - Grazed
50 lbs N / ton
H
Fescue- Hay
50 lbs N / ton
I
Oats
1.3 lbs N / bushel
J
Rye
2.4 lbs N / bushel
K
Small Grain - Grazed
50 lbs N / acre
L
Small Grain - Hay
50 lbs N / acre
M
Grain Sorghum
2.5 lbs N / cwt
N
Wheat
2.4 lbs N / bushel
O
Soybean
4.0 lbs N / bushel
P
Pine Trees
40 lbs N / acre I yr
Q
Matua
50 lbs N / ton
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4 of 8 B00119220597

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PAN/ rfanimal Farm Total/ r
Farrow to Wean 0.84
Farrow to Feeder 1
Farrow to Finish 4.1
Wean to Feeder 0.072
8000 Feeder to Finish 0.36 2880
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 2880 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 14400 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 48 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 115.2 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
'This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5of8
B00119220598

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract
Hydrant
Type
Crop
in/hr
; inches
1498
1
WaB
C
0.6
1
1498
2A
WaB
C
0.6
1
1498
2B
WaB
C
0.6
1
1498
3
WaB
B/C
0.6
1
1498
4
WaB
B/C
0.6
1
1420
5
WaB
C
0.6
1
1420
6
WaB
B/C
0.6
1
1498
7
WaB
B/C
0.6
1
1498
8
WaB
B/C
0.6
1
1498
9
WaB
BIC
0.6
1
1498
10
WaB
B/C
0.6
1
1419
11
NoA
B/C
0.5
1
1419
12
NoA
B/C
0.5
1
1419
13
GbA
B/C
0.5
1
1498
14
WaB
B/C
0.6
1
1498
15
WaB
B/C
0.6
1
6of8
B00119220599

Additional Comments:
This plan revised to show a crop change to a hay/graze combination on the
grazed bermuda fields. Part of the bermuda crop will be removed as hay and
the remaining part by grazing. Matua may be substituted for the small grain if
desired. The application rates and times will be the same as the small grain.
7 of 8 B00119220600

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: BOC #92
Owner: Brown's of Carolina
Manager: David Nordin
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. ilwe know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Brown's of Carolina
Signature:
Name of Manager (if different from owner):
Signature:
David Nordin
Name of Technical Specialist: M. Kevin Weston
Affiliation: _ _ Murphy -Brown, LLC _
Address: 2822 Hwy 24 West, PO Box 856
Warsaw, NC 28398
Telephone: [phone]
Signature:
%q a
Date
8of8
B00119220601

Facility
Waste Management Plan Changes
12 � (70 Farm ZS 7—�
This farms Waste Management Plan has made the following changes:
❑ Crop changes
❑ Wetted Acres
❑ Increased Acreage
❑ Decreased Acreage
❑ Changed Irrigation Design
❑ Change in Farm type
❑ Plan based on 3 Years On Farm Records
0' Other
Comments:
(A- p c, pre J CD, rkt
r -.&IOAc
- I -O
Date
RECEIVED
JUL 01 2004
OW - FAYEfTEVlLLE fiEl';EOML OFFICE

Murphy -Brown, LLC 06/17/2004 P.O. Box 856
Warsaw, NC 26398
NUTRIENT UTILIZATION PLAN
Grower(s):
Farm Name:
Murphy -Brown, LLC
2528
County: Sampson
Farm Capacity:
Farrow to Wean
Farrow to Feeder 1000
Farrow to Finish
Wean to Feeder
Feeder to Finish 3520
Storage Structure:
Storage Period:
Application Method:
Anaerobic Lagoon
>180 days
Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water andlor groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
fi AI V

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, A tons, etc.):
Capacity .----Type Waste Produced per Animal Total
Farrow to Wean
3212 gal/yr
gal/yr
1000
Farrow to Feeder
4015 gal/yr
4,015,000 gal/yr
Farrow to Finish
10585 galtyr
gal/yr
Wean to Feeder
223 gal/yr
gal/yr
3520
Feeder to Finish
986 al/yr
3,470,720 gall r
Total 7,485,720 gal/yr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (Ibs
Capacity Type Nitrogen Produced 12er Animal Total
Farrow to Wean
5.4 lbs/yr
Ibslyr
1000
Farrow to Feeder
6.4 ibs/yr
6,400 Ibs/yr
Farrow to Finish
26 Ibslyr
Ibs/yr
Wean to Feeder
0.48 Ibslyr
ibs/yr
3520
Feeder to Finish
2.3 Ibslyr
8,096 Ibslyr
Total 14,496 Ibslyr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMAR V
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 81.98
Total N Required 1 st Year: 23929.1425
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops 23,929.14
Total Nitrogen Produced by Farm 14,496.00
Nitrogen Balance for Crops: (9,433.14)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2of8

Reception Area Specifications
Tract Field irrigated Soil 1st Crop Time to tat Crop 1st Crop Lbs NlAc Lbs N Total Ibs N
Acreage Type Code Apply Yield Ibs NlUnit Residual JAc Utilized
2nd Crop Time to 2nd Crop 2nd Crap Lbs NIAc Lbs N Total Lbs N
Code Apply Yield Ibs N/Unit Residual lAc Utilized I
Total
Lbs NlAc
Total Ibs N
Utilized
9529
1A
4.38
Paxvllle
M
Apr -Aug
82.4
2.5
206
902.28
L
Sept -Apr
1
100
100
436
306
1340.28
2A
1.61
We ram
M
Apr -Aug
83.5
2.5
209
336.0875
L
Sept-ASept-Ap r
1
100
100
161
308.75
497.0815
2B
4.72
Wa ram
M
Apr -Aug
83.5
2.5
209
985.3
L
Sept -Apr
1
100
100
472
308.75
1457.3
3A
2.54
Wa ram
B
Mar -Sept
5Z
43.25
238
604.2025
K
Se t-A r
1
50
50
127
287.875
731.2025
3B
2.19
Grhney
B
Mar -Set
5.5
43.25
238
520.9463
K
Se t-A r
1
50
50
109.5
287.875
630.4463
7A
4.66
Wa ram
B
Mar -Set
5.5
43.25
238
1108.498 f
K
Sept -Apr
1
50
1
50
233
287.875
1341.498
78
5.29
Wa ram
B
Mar -Sept 1
5.5
43.25
238
1258.3591
K I
Sept -Apr
1
50
1
50
264,5
287.875
1522.859
7C
1.5
Wa ram
B
Mar -Set
5.5
43.25
238
356.8125
K
Sept -Apr
1
50
50
75
287.875
431.8125
8A
3.46
We ram
B
Mar -Sept
5.5
43.25
238
823.0475
K
Se t-A r
1
50
50
173
287,875
996.0475
88
1.81
wa ram
B
Mar -Set
5.5
43,25
238
430.5538
K
Se t-A r
1
50
50
90.5
287,875
521.0538
9A
2.99
Wa ram
B
Mar -Set
5.5
43.25
238
711,2463
K
Se t-A r
1
50
50
149.5
287.875
860.7463
11A
6.11
Wa ram
B
Mar -Set
5.5
43,25
238
1453.416
K
Sept -Apr
1
50
50
305.5
287.875
1758.916
12A
6.11
Wa ram
B
Mar -Set
5.5
43.25
238
1453,416
K
Sa t-A r
1
50
50
305Z
287,875
1758.916
128
3.59 1
Wa ram
B
Mar -Set
5.5
43.25
238
853.9713
K
Se t-A r
1
50
50 1
179.5
287,875
1033.471
12C
4.24
Wa ram
B I
Mar -Set
5.5
43.25
238
1008.59
K
Se t-A r
1
50
50
212
287.875
1220.59
13A
1.5
Paxvllle
M
Apr -Aug
82.4
2.5
206
309
L
Se t-A r
1
100
100
150
306
459
9529
subl
3.43
Paxvitie
M
Apr -Aug
82.4
2.5
206
706.58
L
Se 1-A r
1
100 1
100
343
306
1049.58
sub2
0.92
Wa ram
M
Apr -Aug
83.5
2.5
209
192.05
L
Se t-A r
1
100
too
92
308.75
284.05
sub3
6.28
Wa ram
B
Mar -Set
5.5
43.25
237.875
1493,855
K
Sept -Apr I
1
50
50
314
287.875
1807.855
sub7
7.31
Wa ram
B
Mar -Sept
515
43.25
237.875
1738.866
K
Se t-A r 1
1
50
50
365.5
287.875
2104,366
8ub8
1.55
Wa ram
$
Mar -Set
5.5
43.25
237.875
368.7063
K
Sept -Apr 1
1
So
50
77.5
1 287.875
446.2063
sub9
2.52
Wactram
B
Mar -Set
5.5
43.25
237,875 1
599.445
K
Se t-A r
1
50
50
126
287.875
725.445
sub11
1.28
Wa ram
B
Mar -Sept
5.5
1 43.25
237.875
304.48
K
Ss t-A r
1
50
50
64
287.876
368.48
sub12
1.49
wa ram
B
Mar -Sept
5.5
43.25
237.875
354.4338
K
Sa t-A r
1
50
50
74.5
287,875
428,9338
sub13
0.5
PaxVille
M
Apr -Aug
82.4
2.5
206
103
L
Se t-A r
1
too
100
50
306
153
Totals: 81.96 18917.14 4952 23929.11
3(a) of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e_
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code Crop
Lbs N utilized / unit yield
A Barley
1.6 Ibs N 1 bushel
B Hybrid Bermudagrass - Grazed
50 Ibs N 1 ton
C Hybrid Bermudagrass - Hay
50 Ibs N 1 ton
D Com - Grain
1.25 Ibs N 1 bushel
E Com - Silage
12 Ibs N / ton
F Cotton
0.12 Ibs N 1 Ibs lint
G Fescue - Grazed
50 Ibs N / ton
H Fescue - Hay
50 Ibs N I ton
I Oats
1.3 Ibs N 1 bushel
J Rye
2.4 ibs N 1 bushel
K Small Grain - Grazed
50 ibs N / acre
L Small Grain - Hay
50 Ibs N 1 acre
M Grain Sorghum
2.5 Ibs N I cwt
N Wheat
2.4 ibs N 1 bushel
O Soybean
4.0 Ibs N / bushel
P Pine Trees
40 Ibs N I acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4 of 8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PAN
r/animal Farm Total/ r
Farrow to Wean
0.84
1000 Farrow to Feeder
1 1000
Farrow to Finish
4.1
Wean to Feeder
0,072
3520 Feeder to Finish
0.36 1267.2
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 2267.2 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 11336 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 37 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 90.688 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
'This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5of8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract Hydrant
Type_
Crop
inlhr
*inches _
IIA
Paxville
M
0.45
1
2A
Wagram
M
0.6
1
2B
Wagram
M
0.6
1
3A
Wagram
B
0.6
1
3B
Gritney
B
0.5
1
7A
Wagram
B
0.6
1
7B
Wagram
B
0.6
1
#REI=! 7C
Wagram
B
0.6
1
8A
Wagram
B
0.6
1
8B
Wagram
B
0.6
1
9A
Wagram
B
0.6
1
11A
Wagram
B
0.6
1
12A
Wagram
B
0.6
1
12B
Wagram
B
0.6
1
12C
Wagram
B
0.6
1
13A
Paxville
M
0.45
1
9529 sub1
Paxville
M
0.45
1
sub2
Wagram
M
0.6
1
sub3
Wagram
B
0.6
1
sub?
Wagram
B
0.6
1
sub8
Wagram
B
0.6
1
sub9
Wagram
B
0.6
1
sub11
Wagram
B
0.6
1
sub12
Wagram
B
0.6
1
sub13
Paxville
M
0.45
1
6of8

Additional Comments:
The nitrogen rate used for bermuda pasture in this plan represents
a graze/hay combination. At least one cutting of hay will be removed from these
fields each year.
Aerway acreage listed is optional land for application.
7of8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: 2528
Owner: Murphy -Brown, LLC
Manager:
Owner/Manager Agreement:
Ilwe understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. Ilwe know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
Ilwe understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Murphy -Brown, LLC
Signature:
Date
Name of Manager (if different from owner):
Signature: -1-7 A
Date
Name of Technical Specialist:
Dawn Williamson
Affiliation:
Murphy -Brown, LLC.
Address: _
^
2822 Hwy 24 West, PO Drawer 856
- -
Warsaw, NC 28398
Telephone:
[phone] _
Signature:
Date
8of8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recievinq crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2of3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3of3

i
Waste Management Plan Changes
Facility (� Z � 3 Farm Cam` A l
This farms Waste Management Plan has made the following changes:
❑ Crop changes
❑ Wetted Acres
❑ Increased Acreage
❑ Decreased Acreage
❑ Changed Irrigation Design
❑ Change in Faun type
❑ Plan based on 3 Years On Farm Records
2(other
Comments:
Date
RECEIVED
JUL 01 2004
DEM _ FAYEit U.E RMOW1 O CE

Murphy -Brown, LLC
Grower(s):
Farm Name:
06/16/2004 P.O. Box 856
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Murphy -Brown, LLC
C&MI
County: Sampson
Farm Capacity:
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish 6000
Storage Structure:
Storage Period:
Application Method:
Anaerobic Lagoon
>180 days
Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission,
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, tj tons, etc.):
Capacity Type Waste Produced per Animal Total
Farrow to Wean
3212 gailyr
galtyr
Farrow to Feeder
4015 ga1/yr
gal/yr
Farrow to Finish
10585 gallyr
gal/yr
Wean to Feeder
223 gallyr
gal/yr
6000
Feeder to Finish
986 gall r
5,916,000 gall r
Total 5,916,000 gall r
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (Ibs
Capacity Type Nitrogen Produced per Animal Total
Farrow to Wean
5.4 lbs/yr
lbs/yr
Farrow to Feeder
6.5 lbs/yr
lbs/yr
Farrow to Finish
26 lbs/yr
lbs/yr
Wean to Feeder
0.48 lbs/yr
lbs/yr
6000
Feeder to Finish
2.3 lbs/yr
13,800 lbs/yr
Total 13,800 lbs/yr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION 5UMMARIV
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 93.84
Total N Required 1 st Year: 28022.8975
Total N Required 2nd Year: 24836.7325
Average Annual Nitrogen Requirement of Crops 26,429.82
Total Nitrogen Produced by Farm 13,800.00
Nitrogen Balance for Crops: (12,629.82)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2of8

2A
4.05
Norfolk
B
I Mar -Set
6.5
1 43.25
281,125
1 1138.556
K
I Sept -Apr
1
1 50
50
202.5
331,125
1 1341.056
2B
6.32
Norfolk
B
Mar -Sept
6.5
43.25
281.125
1776.71
K
Sept -Apr
1
50
50
318
331.125
2092.71
2C
1.69
Norfolk
B
Mar -Set
6.5
43.25
281.125
475.1013
K
Sept -Apr
1
50
50
84,5
331.125
559.6013
3(a) of 8

r Tract Field Irrigated Soil let Crop Time to 1st Crop 1st Crop Lbs N/Ac Lbs N Total lbs NI2nd Crop Time to 2nd Crop 2nd Crop Lbs NIAc Lbs N Total We N� Total I Total Ibs NI
I Acreaae Tvne Code Aoolv Yield Ills NlUnit Residual IAc Utilized Cade Aooly Yield Ibs NlUnit Residual !Ac Utilized Lbs NIA c Utlltzed
�c!iGli►_1ii'�I:i �:T.Tif.117i=�� r f:3ZCY_TS1tilF.itiS�b�iti�I:iRiY�tyt:i:iR.�:Y/.yii �t�'I.T.Sa_Riitiii�i�ti."_r>•iYlciti�XiliY�y lciti�".:tL.�
2A
1 4.05
1 Norfolk 1
B
I Mar -Set 1
6.5
43.25 1
1281.125
1 1138.556 1
K
I Sept -Apr 1
1
1 50 1
1
50
1 202.5
1 331.125
1341.056
2B
1 5.32
1 Norfolk I
B
I Mar -Set 1
6,5
43.25 1
1
281.125
1 1776.71 I
K
I Sept -Apr 1
1
1 50 1
50
1 316
1 331.125
2092.71
2C
1 1.69
1 Norfolk
BMar-Set
6.5
43.25 1
1
281,125
1475.10131
K
I Se t-A r 1
1
1 50
50
1 84.5
1 331.125
559.801-A
3(b) of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields (i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized / unit yield
A
Barley
1.6 lbs N 1 bushel
B
Hybrid Bermudagrass - Grazed
50 lbs N I ton
C
Hybrid Bermudagrass -flay
50 lbs N / ton
D
Com - Grain
1.25 lbs N 1 bushel
E
Com - Silage
12 lbs N 1 ton
F
Cotton
0.12 Ibs N / lbs lint
G
Fescue - Grazed
50 lbs N I ton
H
Fescue - Hay
50 lbs N 1 ton
I
Oats
1.3 lbs N 1 bushel
J
Rye
2.4 lbs N / bushel
K
Small Grain - Grazed
50 lbs N 1 acre
L
Small Grain - Hay
50 lbs N 1 acre
M
Grain Sorghum
2.5 lbs N / cwt
N
Wheat
2.4 lbs N I bushel
O
Soybean
4.0 lbs N I bushel
P
Pine Trees
40 lbs N / acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PANT danimal Farm Total/r
Farrow to Wean 0.84
Farrow to Feeder 1
Farrow to Finish 4.1
Wean to Feeder 0.072
6000 Feeder to Finish 0.36 2160
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 2160 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 10800 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 36 acreas of land. If you apply the sludge
to com at a rate of 125 pounds per acre, you will need 86.4 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
`This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated property to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5of8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract
Hydrant
Type
Crop
inlhr
* inches
1A
Norfolk
B
0.5
1
2A
Norfolk
B
0.5
1
2B
Norfolk
B
0.5
1
2C
Norfolk
B
0.5
1
2D
Norfolk
B
0.5
1
4A
Wagram
B
0.6
1
4B
Wagram
B
0.6
1
#REF!
4C
Wagram
B
0.6
1
4D
Wagram
B
0.6
1
4E
Wagram
B
0.6
1
5A
Norfolk
B
0.5
1
5B
Norfolk
B
0.5
1
5C
Norfolk
B
0.5
1
12412
1
Norfolk
D
0.5
1
2
Norfolk
D
0.5
1
3
Norfolk
D
0.5
1
5
Norfolk
D
0.5
1
6
Wagram
D
0.6
1
3410
sub2
Norfolk
B
0.5
1
sub4
Wagram
B
0.6
1
sub5
Norfolk
B
0.5
1
6 of 8

Additional Comments:
The nitrogen rate used for bermuda pasture in this plan represents
a graze/hay combination. At least one cutting of hay will be removed from these
fields each year. _ _
Application on Tract 12412 and all sub fields will be made with aerway machine.
The acreage/crops listed on this land are optional for PAN balance on this farm.
7 of 8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: C & M I
Owner. Murphy -Brown, LLC
Manager.
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
Itwe understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be fled on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Murphy -Brown, LLC
Signature:
Date
Name of Manager (if different from owner):
Signature: AUW rr�
Date
Name of Technical Specialist:
Dawn Williamson
Affiliation:
Murphy -Brown, LLC.
Address:
2822 Hwy 24 West, PO Drawer 856
Warsaw, NC 28398
Telephone:
[phone]
Signature:
Date
8of8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
Z There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recievinq crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner_
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season_
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3of3

RECEIVED
Waste Management Plan Changes JUL a 1 2004
oBR-FAWWUEREG[oM CFRCE
Facility O 2— / Farm Z 1 g -4 Cd- Ail
This farms Waste Management Plan has made the following changes:
❑ Crop changes
❑ Wetted Acres
❑ Increased Acreage
❑ Decreased Acreage
❑ Changed Irrigation Design
❑ Change in Farm type
❑ Plan based on 3 Years On Farm Records
VOther
Comments:
(o l s-
Date

Murphy -Brown, LLC
Grower(s):
Farm Name:
06/16/2004 P.Q. Box 856
Warsaw, NC 28396
NUTRIENT UTILIZATION PLAN
Murphy -Brown, LLC
2148/C&M11
County: Sampson
Farm Capacity.
Farrow to Wean
Farrow to Feeder 1400
Farrow to Finish
Wean to Feeder
Feeder to Finish 8000
Storage Structure:
Storage Period:
Application Method:
Anaerobic Lagoon
>180 days
Irrigation
The waste from your animal facility must be land applied at a specked rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, It tons, etc.):
Capacity Type Waste Produced per Animal Total
Farrow to Wean
3212 gally►
gal/yr
1400
Farrow to Feeder
4015 galtyr
5,621,000 gal/yr
Farrow to Finish
10585 gal/yr
gal/yr
Wean to Feeder
223 gal/yr
gal/yr
8000
Feeder to Finish
986 galtyr
7,888,000 galtyr
Total 13,509,000 gallr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs
-Capacity Type Nitrogen Produced per Animal Total
Farrow to Wean
5.4 Ibstyr
Ibstyr
1400
Farrow to Feeder
6.5 Ibs/yr
9,100 Ibstyr
Farrow to Finish
26 Ibslyr
Ibslyr
Wean to Feeder
0.48 Ibslyr
Ibslyr
8000
Feeder to Finish
2.3 Ib!g r
18,400 Ibstyr
Total 27,500 Ibslyr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 124.28
Total N Required 1 st Year: 38569.7575
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops 38,569.76
Total Nitrogen Produced by Fans 27,500.00
Nitrogen Balance for Crops: (11,069.76)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2 of 8

18
8.33
We ram
B
Mar -Sept
5.5
43.25
237-875
1267.874
K
Sept -Apr
1
50
50
266.5
287.875
1534.374
1C
0.75
Wa ram
B
Mar -Set
5.5
43,25
237.675
178.4063
K
Se tI r
1
50
50
37.5
287.875
215.9063
iQ
4.85
We ram
B
Mar -Set
5.5
43.25
237.875
1106.119
K
Se t-A
1
50
50
232.5
287.875
1338.618
1
1t?
0.75
Wa ram
B
Mar -Sept t
5.5
43,25
237,875
178.4063
K
Sept -Apr
1
50
50
37.5
287,875
215,9063
3(a) of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In inter -planted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal Ume to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N ublized 1 unit yield
A
Barley
1.6 Ibs N 1 bushel
B
Hybrid Bermudagrass - Grazed
50 Ibs N / ton
C
Hybrid Bermudagrass - Hay
50 Ibs N I ton
D
Corn - Grain
1.25 Ibs N 1 bushel
E
Corn - Silage
12 Ibs N / ton
F
Cotton
0.12 Ibs N I Ibs lint
G
Fescue - Grazed
50 Ibs N / ton
H
Fescue- Hay
50 Ibs N / ton
I
Oats
1.3 Ibs N / bushel
J
Rye
2.4 Ibs N / bushel
K
Small Grain - Grazed
50 Ibs N / acre
L
Small Grain - Hay
50 ibs N / acre
M
Grain Sorghum
2.5 Ibs N / cwt
N
Wheat
2.4 ibs N 1 bushel
O
Soybean
4.0 Ibs N 1 bushel
P
Pine Trees
40 Ibs N 1 acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PAN r/animal Farm Tota r
Farrow to Wean 0.84
1400 Farrow to Feeder 1 1400
Farrow to Finish 4.1
Wean to Feeder 0.072
8000 Feeder to Finish 0.36 2880
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 4280 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 21400 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 71 acreas of land. If you apply the sludge
to com at a rate of 125 pounds per acre, you will need 1712 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months_ In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract Hydrant
Type
_Crop
in/hr
" inches
1A
Wagram
B
0.6
1
1 B
Wagram
B
0.6
1
IC
Wagram
B
0.6
1
1 D
Wagram
B
0.6
1
1 E
Wagram
B
0.6
1
1 F
Wagram
B
0.6
1
1 G
Wagram
B
0.6
1
#REF! 1 H
Wagram
B
0.6
1
4A
Norfolk
B
0.5
1
4B
Norfolk
B
0.5
1
4C
Norfolk
B
0.6
1
4D
Norfolk
B
0.5
1
4E
Norfolk
B
0.5
1
4F
Norfolk
B
0.5
1
4G
Norfolk
B
0.5
1
7A
Norfolk
B
0.5
1
7B
Norfolk
B
0.5
1
7C
Norfolk
B
0.5
7D
Wagram
B
0.6
1
7E
Wagram
B
0.6
1
7G
Wagram
B
0.6
1
8A
Norfolk
B
0.5
1
8B
Norfolk
B
0.5
1
8C
Norfolk
B
0.5
1
8D
Norfolk
B
0.5
1
3408 subl
Wagram
B
0.6
1
sub4
Norfolk
B
0.5
1
sub7a-e
Wagram
B
0.6
1
sub7g
Wagram
B
0.6
1
6of8

Additional Comments:
The nitrogen rate used for bermuda pasture in this plan represents
a graze/hay combination. At least one cutting of hay will be removed from these
+fields each year.
Application on sub fields will be made with an aerway machine.
7 of 8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: 21481C R M II
Owner: Murphy -Brown, LLC
Manager:
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Murphy -Brown, LLC
Signature:
Name of Manager (if different from owner):
Signature:
Date
/ ( -a C4
Date
Name of Technical Specialist: Dawn Williamson
Affiliation: Murphy -Brown, LLC.
Address: 2822 Hyy 24 West, PO Drawer 856
Warsaw, NC 28398
Telephone: [phone]
Signature:
Date
8of8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recievinq crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 torts per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
{continued}
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner_
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2of3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers_ A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3of3

i
Waste Management Plan Changes
RECEIVED
JUL 01 2004
©ENR- FAYETIENILLE REGIONAL OFRCE
Facility _ IS J1 1 Farm 101 5 4 76 7
This farms Waste Management Plan has made the following changes:
❑ Crop changes
❑ Wetted Acres
❑ Increased Acreage
❑ Decreased Acreage
❑ Changed Irrigation Design
❑ Change in Farm type
❑ Plan based on 3 Years On Farm Records
21"Other
Comments:
At
t4l-S -6f (0, 4-+

Murphy -Brown, LLC 06/15/2004 2$2 P.w 24 West
O.56
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Grower(s):
Farm Name:
Murphy -Brown, LLC
7075 & 7076
County: Robeson
Farm Capacity:
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish 17600
Storage Structure:
Storage Period:
Application Method:
Anaerobic Lagoon
>180 days
Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, A tons, etc.):
Capacity Type Waste Produced per Animal Total
Farrow to Wean
3212 galtyr
gal/yr
Farrow to Feeder
4015 galtyr
gal/yr
Farrow to Finish
10585 gal/yr
gal/yr
Wean to Feeder
223 ga/yr
gal/yr
17600
Feeder to Finish
986 ailyr
17,353,600 galtyr
Total 17,353,600 gall r
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (Ibs
Capacity Type Nitrogen Produced r Animal Total
Farrow to Wean
5.4 lbs/yr
lbs/yr
Farrow to Feeder
6.5 Ibstyr
lbs/yr
Farrow to Finish
26 lbs/yr
Ibstyr
Wean to Feeder
0.48 lbs/yr
lbs/yr
17600
Feeder to Finish
2.3 lbs/yr
40,480 lbs/yr
Total 40,480 lbs/yr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 186.6
Total N Required 1st Year. 47901.475
Total N Required 2nd Year. 43226.375
Average Annual Nitrogen Requirement of Crops 45,563.93
Total Nitrogen Produced by Farm 40,480.00
Nitrogen Balance for Crops; (5,083.93)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2of8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized / unit yield
A
Barley
1.6 lbs N / bushel
B
Hybrid Bermudagrass - Grazed
50 lbs N 1 ton
C
Hybrid Bermudagrass - Hay
50 lbs N 1 ton
D
Corn - Grain
1.25 lbs N / bushel
E
Corn - Silage
12 lbs N 1 ton
F
Cotton
0,12 lbs N / lbs lint
G
Fescue- Grazed
50 lbs N 1 ton
H
Fescue - Hay
50 lbs N 1 ton
I
Oats
1.3 lbs N / bushel
J
Rye
2.4 lbs N / bushel
K
Small Grain - Grazed
50 lbs N / acre
L
Small Grain - Hay
50 lbs N 1 acre
M
Grain Sorghum
2.5 lbs N / cwt
N
Wheat
2.4 lbs N 1 bushel
O
Soybean
4.0 lbs N 1 bushel
P
Pine Trees
40 lbs. N 1 acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PAN rlanimal Farm Totaltyr
Farrow to Wean 0.84
Farrow to Feeder 1
Farrow to Finish 4.1
Wean to Feeder 0.072
17600 Feeder to Finish 0.36 6336
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 6336 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 31680 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 105 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 253.44 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
"This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Cali your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5of8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract Hydrant
Type
Crop
inlhr
inches
34836 1
Goldsboro
B
0.4
1
2
Lynchburg
B
0.65
1
3
Rains
F
0.4
1
4
Lynchburg
F
0.65
1
5
Goldsboro
F
0.4
1
6of8

ao
0
P

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: 7075 & 7076
Owner: Murphy -Brown, LLC
Manager:
Owner/Manager Agreement:
Itwe understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
11we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Murphy -Brown, LLC
Signature:
Date
Name of Manager (if different from owner):
Signature;
Date
Name of Technical Specialist:
Dawn Williamson
Affiliation:
Murphy -Brown, LLC.
Address:
2822 Hwy 24 West, PO Drawer 856
Warsaw, NC 28398
Telephone:
910293-3434
Signature:
6-IS —(D
Date
8of8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to property dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recieving crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies-
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Wastelnutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum Crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3of3

MurphrBrown, LLC
Grower(s):
Farm Name:
07/09/2003 P.Q. Box 856
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Murphy -Brown, LLC
Owens Branch Amendment
County: Sampson
Farm Capacity:
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder 11200
Feeder to Finish 4896
Storage Structure:
Storage Period:
Application Method:
Anaerobic Lagoon
>180 days
Irrigation
RECEIVED
JUL 01 2004
OW - FAYETTE11 U FMOVAL OFACE
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized 1 unit yield
1
1
A
Barley
1.6 lbs N / bushel
B
Hybrid Bermudagrass - Grazed
50 lbs N ! ton
C
Hybrid Bermudagrass - Hay
50 lbs N / ton
D
Com - Grain
1.25 lbs N / bushel
E
Com - Silage
12 lbs N I ton
F
Cotton
0.12 lbs N / lbs lint
G
Fescue- Grazed
50 lbs N / ton
H
Fescue - Hay
50 lbs N / ton
I
Oats
1.3 lbs N 1 bushel
J
Rye
2.4 lbs N / bushel
K
Small Grain - Grazed
50 lbs N 1 acre
L
Small Grain - Hay
50 lbs N / acre
M
Grain Sorghum
2.5 lbs N / cwt
N
Wheat
2.4 lbs N 1 bushel
O
Soybean
4.0 lbs N 1 bushel
P
Pine Trees
40 lbs N / acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract
Hydrant
Type
Crop
Inlhr
* inches`
OwBr
'subl
Norfolk
O
_
0.5
1
OwBr.
sub2
Goldsboro
O
0.4
1
OwBr
sub3
Goldsboro
O
0.4
1
OwBr
sub4
Goldsboro
O
0.4
1
OwBr
subs
Goldsboro
O
0.4
1
OwBr
sub6
Leon
O
0.65
1
sub?
Leon
O
0.65
1
#REFI
6of8

Additional Comments:
The acreage listed on this amendment Is the balance of the total field acreage
minus the wetted acres at this site. The areas not covered by the conventional
irrigation system are being entered into the pumping records as sub fields
so that the acres can be claimed when making application with an Aerway
machine.
7of8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: Owens Branch Amendment
Owner: Murphy -Brown, LLC
Manager:
Owner/Manager Agreement:
Ilwe understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. Ilwe know that any expansion to the existing design capacity
of the waste treatment andlor storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
Ifwe understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil' and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Murphy -Brown, LLC
Signature: / 7-1-03
Date
Name of Manager (if different from owner):
Signature: `' z7
Date
Name of Technical Specialist:
Dawn Williamson
Affiliation:
Murphy -Brown, LLC
Address:
2822 Hwy 24 West, PO Drawer 856
Warsaw, NC 28398 -
_
Telephone:
[phone]
Signature:
Date
8 of 8

Bois
FMOM
key
rMT? , YK
J
o"I VX"OR Stu
5.
zo-�
Egg Maps. - -g-kA Qlal1w V 'I,"
ow,
w M
Al
g'Ph
�A34 '. n,
TM zy,-` MQ -0 k
1�.. 'Ar
P
AW
-0, ;i,'Sr
'AM
ah'N•AW
;�16-•RRI 'T
ail
--C ZAI4.A
ioiy 14- 11-
L
Iff-
it � �Wlw�
aws; r, L-
MR
Up. M
Ij -AQ , 6�
wn
Two
ON
Sw %A
i4 �t4iP �0- T
J.;4 A-1 ""I
MUM,
r it-4'
e
ON i,
.0,
aO
I�X
�J-
sum
oe ia:4�3srr t r
xsr,,&p 1: A
cgs t, 'It
-ALl

Murphy -Brown, LLC
h
07/21/2004
IL
TION PLAN
Grower(s): ON—FAWMERIDO All�CE urphy- 2
Farm Name: 3092
waoen
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish 8000
Structure:
Storage Period:
Application Method:
>180 days
Irrigation
2822 Hwy 24 West
P.O. Box 856
Warsaw, NC 28398
RECEIVED I DENR I D►NCI
A,g11,tfar protertton Smfign
APR 0 9 2009.
_agoon
The waste from your animal facility must be land applied at a.specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1 _ Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize_
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, A tons, etc.):
Capacity Type Waste Produced per Animal Total
Farrow to Wean
3212 gallyr
gallyr
Farrow to Feeder
4015 gallyr
galtyr
Farrow to Finish
10585 gal/yr
gal/yr
Wean to Feeder
223 gallyr
gallyr
8000
Feeder to Finish
422.100 al/yr
3,376,843 gal/yr
Total 3,376,843 gall r
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (Ibs
Capacity Type Nitrogen Produced per Animal Total
Farrow to Wean
5.4 Ibs/yr
Ibs/yr
Farrow to Feeder
6.5 Ibs/yr
lbs/yr
Farrow to Finish
26 Ibs/yr
Ibs/yr
Wean to Feeder
0.48 Ibs/yr
Ibs/yr
8000
Feeder to Finish
1.057 Ibslyr
8,459 Ibs/yr
Total 8,459 lbs/yr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 54.94
Total N Required 1st Year: 16344.8
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops 16,344.80
Total Nitrogen Produced by Farm 8,459.00
Nitrogen Balance for Crops: (7,885.80)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2 of 8

'Reception Are Specifications
Acreage TYP, Code .._
OfbF�,
�0MUM
®
3(a) of 8

'Reception
Tract Field Irrigated Soll I st Crop Time to 1stCrop Istcrop LbsNIAc Lbs N Totall w 0� M�Erwm
Acreage Type Code Apply Yle d lbs N/Unit FtesWuW /Ac---Utillzej)m Ow Ri OEM=
--------------------
--------------- ---- -
3(b) of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized I unit yield
A
Barley
1.6 lbs N 1 bushel
B
Hybrid Bermudagrass - Grazed
50 lbs N 1 ton
C
Hybrid Bermudagrass - Hay
50 lbs N 1 ton
D
Corn - Grain
1.25 lbs N 1 bushel
E
Corn - Silage
12 lbs N / ton
F
Cotton
0.12 lbs N I lbs. lint
G
Fescue - Grazed
50 lbs N / ton
H
Fescue - Hay
50 lbs N / ton
I
Oats
1.3 lbs N / bushel
J
Rye
2.4 lbs N 1 bushel
K
Small Grain - Grazed
50 lbs N 1 acre
L
Small Grain - Hay
50 lbs N 1 acre
M
Grain Sorghum
2.5 lbs N 1 cwt
N
Wheat
2.4 lbs N 1 bushel
O
Soybean
4.0 lbs N 1 bushel
P
Pine Trees
40 lbs N 1 acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PANT rlanimal Farm Totall r
Farrow to Wean 0.84
Farrow to Feeder 1
Farrow to Finish 4.1
Wean to Feeder 0.072
8000 Feeder to Finish 0.36 2880
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 2880 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 14400 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 48 acreas of land. If you apply the sludge
to com at a rate of 125 pounds per acre, you will need 115.2 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
*This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm_
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract Hydrant
Type
'Crop_�
inlhr
* inches
1498 2A
Wagram
B
0.6
1
2B
Wagram
B
0.6
1
3
Wagram
B
0.6
1
4
Wagram
B
0.6
1
5
Wagram
B
0.6
1
6
Wagram
B
0.6
1
7
Wagram
B
0.6
1
8
Wagram
B
0.6
1
9
Wagram
B
0.6
1
10
Wagram
B
0.6
1
11
Norfolk
B
0,5
1
12
Norfolk
B
0.5
1
13
Goldsboro
B
0.4
1
14
Wagram
B
0.6
1
15
Wagram
B
0.6
1
Me

Additional Comments:
The Bermuda rate in this plan is a combination of hay & graze. At least
half the bermuda will be removed as hay.
7of8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: 3092
Owner: Murphy -Brown, LLC
Manager:
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ.upon request.
Name of Facility Owner:
Signature:
Murphy -Brown, LLC
Name of Manager (if different from owner):
Signature:
Date
Date
Name of Technical Specialist: Dawn Williamson
Affiliation: Murphy -Brown, LLC.
Address: _2822 Hwy 24 West, PO Drawer 856
Warsaw, NC 28398
Telephone: [phone]
Signature:
Date
8 of 8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recieving crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips),
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2of3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3 of 3

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Coleen H. Sullins, Director
Division of Water Quality
July 1, 2007
Murphy -Brown, LLC h
Farm 92 ^-.
,
PO Box 856 ji n, 2 7 -
Warsaw, NC 28398
Subject: Certificate of Coverage No. AWS090181
Farm 92
Animal Waste Management System
Bladen County
Dear Murphy -Brown, LLC:
In accordance with your application received on 1 I -Jun-07, we are hereby forwarding to you this
Certificate of Coverage (COC) issued to Murphy -Brown, LLC, authorizing the operation of the subject
animal waste management system in accordance with General Permit AWG100000,
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for the Farm 92, located in Bladen County, with an animal capacity of no greater than the
following swine annual averages:
Wean to Finish: 0 Feeder to Finish: 8000 Boar/Stud: 0
Wean to Feeder: 0 Farrow to Wean: 0 Gilts: 0
Farrow to Finish: 0 Farrow to Feeder: 0
If this is a Farrow to Wean or Farrow to Feeder operation, there may also be one boar for each 15 sows.
Where boars are unneccessary, they may be replaced by an equivalent number of sows. Any of the sows
may be replaced by gilts at a rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009 and replaces the NPDES
COC issued to this facility with an expiration date of July 1, 2007. You are required to continue
conducting annual surveys of sludge accumulation in all lagoons at your facility; the one-year extension
in Condition Ill.19 does not apply.
Pursuant to this COC, you are authorized and required to operate the system in conformity with the
conditions and limitations as specified in the General Permit, the facility's CAWMP, and this COC. An
adequate system for collecting and maintaining the required monitoring data and operational information
must be established for this facility. Any increase in waste production greater than the certified design
capacity or increase in number of animals authorized by this COC (as provided above) will require a
modification to the CAWMP and this COC and must be completed prior to actual increase in either
wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Enclosed for your convenience is
a package containing the new and revised forms used for record keeping and reporting. Please nay
careful attention to the record keeping and monitoring conditions in this permit.
Aquifer Protection Section 1636 Mail Service Center
Internet: 3nM.ncwaterguali , .org location: 2728 Capital Boulevard
An Equal Opportunity/Affirmative Action Employer— 50% Recycled110% Post Consumer Paper
Orr
NV k Carolina
)WwrallV
Raleigh, NC 27699-1636 Telephone: [phone]
Raleigh. NC 27604 Fax 1: [phone]
Fax 2: [phone]
Customer Service: [phone]

If your Waste Utilization Plan has been developed based on site -specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 02T .0111(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100-foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Per 15A NCAC 02T .1306, any containment basin, such as a lagoon or waste storage structure, shall
continue to be subject to the conditions and requirements of the facility's permit until closed to NRCS
standards and the permit is rescinded by the Division.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Aquifer Protection staff may be reached at 910433-3300. If you need additional information concerning
this COC or the General Permit, please contact the Animal Feeding Operations Unit staff at (919) 733-
3221.
Sincerely,
for Coleen H. Sullins
Enclosures (General Permit AWG100000, Record Keeping and Reporting Package)
cc: (Certificate of Coverage only for all cc's)
Bladen County Health Department
Bladen County Soil and Water Conservation District
Fayetteville Regional Office, Aquifer Protection Section
AFO Unit Central Files
Permit File AW S090181

WASTE UTILIZATION PLAN
NPDES PERMIT RENEWAL - 2007
REGIONAL OFFICE - APS
FARM NO:
❑ ASHEVILLE
FAVETTEVILLE
❑ MOOREfVILLE
❑ RALEIGH
❑ WASHINGTON
❑ WILMINGTON
❑ WINSTON-SALEM

Murphy -Brown, LLC 07/21/2004 2822 Hwy 24 West
P.O. Box 856
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Grower(s): Murphy -Brown, LLC
Farm Name: 3092
Coun : Bladen
Farm Capacity:
Farrow to Wean
Farrow to Feeder RECEIVED / DENR 1 DWQ
Farrow to Finish AQU1FFR'PPnTFrTinN SECTION
Wean to Feeder DEC 2 7 200fi
Feeder to Finish 8000
Storage Structure: Anaerobic Lagoon
Storage Period: >180 days
Application Method: Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, it tons, etc.):
Capacity Tyee Waste Produced per Animal Total
Farrow to Wean
3212 gal/yr
gaUyr
Farrow to Feeder
4015 galtyr
gaUyr
Farrow to Finish
10585 gaUyr
gaUyr
Wean to Feeder
223 gaUyr
gaUyr
8000
Feeder to Finish
422.100 gal/yr
3,376,843 gaUyr
Total 3,376,843 gallyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs
Capacity Type Nitrogen Produced per Animal Total
Farrow to Wean
5.4 lbs/yr
Ibslyr
Farrow to Feeder
5.5 lbs/yr
Ibslyr
Farrow to Finish
26 lbs/yr
lbs/yr
Wean to Feeder
0.48 lbs/yr
lbs/yr
8000
Feeder to Finish
1.057 lbs/yr
8,459 lbs/yr
Total 8,459 Ibslyr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 54.94
Total N Required 1 st Year: 16344.8
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops 16,344.80
Total Nitrogen Produced by Farm 8,459.00
Nitrogen Balance for Crops: (7,885.80)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2 of 8

,Reception
Acreage Type Code Apply Yleld lbs NfUnIt Residual fAc UtIlizem.
M-. MM
����a�®���■■����©moo■���o��r�
�m
�o��zm���®�■�■��m©�a��■�r�N�®�
corn
®r��v�a�®����m��ma�������
���■ar®���tv
� - =
�®ate■■��r
, , .
■���r���©�����
3(a) of 8

Reception Area Specifications
Tract Field Irrig . ated Soil let .. Time to
Acreage Tygo Code AppJy Yield lbs N[Unit Residual IAc Utilized
3(b) of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, andlor silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of Bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation; you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is. planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized 1 unit yield
A
Barley
1.6 lbs N 1 bushel
B
Hybrid Bermudagrass - Grazed
50 lbs N 1 ton
C
Hybrid Bermudagrass - Hay
50 lbs N / ton
D
Com - Grain
1.25 lbs N 1 bushel
E
Com - Silage
12 lbs N / ton
F
Colton
0.12 lbs N 1 lbs lint
G
Fescue - Grazed
50 lbs N 1 ton
H
Fescue - Hay
50 lbs N 1 ton
I
Oats
1.3 lbs N 1 bushel
J
Rye
2.4 lbs N 1 bushel
K
Small Grain - Grazed
50 lbs N 1 acre
L
Small Grain - Hay
50 lbs N 1 acre
M
Grain Sorghum
2.5 lbs N 1 cwt
N
Wheat
2.4 lbs N 1 bushel
O
Soybean
4.0 lbs N 1 bushel
P
Pine Trees
40 lbs N 1 acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4 of 8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PANT rlanimal Farm Total/ r
Farrow to Wean 0.84
Farrow to Feeder 1
Farrow to Finish 4.1
Wean to Feeder 0.072
8000 Feeder to Finish 0.36 2880
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 2880 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 14400 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayiand at the
rate of 300 pounds of nitrogen per acre, you will need 48 acreas of land. If. you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 115.2 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be detennined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
*This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract Hydrant
Type
Crop
_ in/hr
' inches
1498. 2A
Wagram
B
0.6
1
2B
Wagram
B
0.6
1
3
Wagram
B
0.6-
1
4
Wagram
B
0.6
1
5
Wagram
B
0.6
1
6
Wagram
B
0.6
1
7
Wagram
B
0.6
1
8
Wagram
B
0.6
1
9
Wagram
B
0.6
1
10
Wagram
B
0.6
1
11
Norfolk
B
0.5
1
12
Norfolk
B
0.5
1
13
Goldsboro
B
0.4
1
14
Wagram
B
0.6
1
15
Wagram
B
0.6
1
6 of 8

Additional Comments:
The bermuda rate in this plan is a combination of hay & graze. At least
half the bermuda will be removed as hay.
7of8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: 3092
Owner: Murphy -Brown, LLC
Manager:
Owner/Manager Agreement:
Ilwe understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
Ilwe understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify thatthe waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Murphy -Brown, LLC
Signature:
Date
Name of Manager (if different from owner):
Signature:xoue�--. -v
4
Date
Name of Technical Specialist:
Dawn Williamson
Affiliation:
Murphy -Brown, LLC. _
Address:
2822 Hwy 24 West, PO Drawer 856 _
Warsaw, NC 28398
Telephone: _
i910) 293-3434
Signature:
Date
8of8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recievinq crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge..
18 if animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH, shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3 of 3

ANIMAL FACILITY ANNUAL CERTIFICATION FORM C
Certificate of Coverage or Permit Number NCA209181 County Bladen Year 2003
Facility Name (as shown on Certificate of Coverage or Permit) Farm 92
Operator in Charge for this Facility John S. Cain, Sr. Certification # 23570
Land application of animal waste as allowed by the above permit occurred during the past calendar year
X Yes No. If NO, skip Part I and Part II and proceed to the certification. Also, if animal waste was
generated but not land applied, please attach an explanation on how the animal waste was handled.
Part 1: Facility Information:
1. Total number of application Fields ❑or Pulls [.(please check the appropriate box) in the Certified Animal
Waste Management Plan (CAWMP): F-N/A/P-16 Total Useable Acres approved in the CAWMP
57.34
2. Total number of Fields ❑ or Pulls - "lease check the appropriate box) on which land application
occurred during the year: F N/A-P15 Total Acres on which waste was applied 56.73
3. Total pounds of Plant Available Nitrogen (PAN) applied during the year for all application sites:
11,267.20
4. Total pounds of Plant Available Nitrogen (PAN) allowed to be land applied annually by the CAWMP and
the permit: 18.444.01
5. Estimated amount of total manure, litter and process wastewater sold or given to other persons and taken
off site during the year ❑ tons ❑ or gallons (please check the appropriate box) R ECt—I VED
6. Annual average number of animals by type at this facility during the previous year:
N/A Information provided by May 1. 2004
r,':y.T==: -:•;:a i-.� ram-
7.Largest and smallest number of animals by type at this facility at any one time during the previousL�;a,�o . L I�.'ti Get
Largest N/A
Smallest N/A
(These numbers are for informational purposes only since the only permit limit on the number of animals
at the facility is the annual average numbers)
8. Facility's Integrator if applicable: f�A vur oV%%A
Part I1: Facility Status:
IF THE ANSWER TO ANY STATEMENT BELOW IS "NO". PLEASE PROVIDE A WRITTEN
DESCRIPTION AS TO WHY THE FACILITY WAS NOT COMPLIANT, THE DATES OF ANY NON
COMPLIANCE, AND EXPLAIN CORRECTIVE ACTION TAKEN OR PROPOSED TO BE TAKEN TO
BRING THIS FACILITY BACK INTO COMPLIANCE.
Only animal waste generated at this facility was applied to the permitted sites during &?,Yes ❑ No
the past calendar year.

2. The facility was operated in such a way that there was no direct runoff of waste from ErYes ❑ No
the facility (including the houses, lagoons/storage ponds and the application sites) during
the past calendar year_
3. There was no discharge of waste to surface water from this facility during the past C3Yes ❑ No
calendar year.
4. There was no freeboard violation in any lagoons or storage ponds at this facility during G2'Yes ❑ No
past calendar year.
5. There was no PAN application to any fields or crops at this facility greater than the 9-Yes ❑ No
levels specified in this facility's CAWMP during the past calendar year.
G. All land application equipment was calibrated at least once during the past calendar year. U-' es ❑ No.
7.
Sludge accumulation in all lagoons did not exceed the volume for which the lagoon
was designed or reduce the Iagoon's minimum treatment volume to less than the volume
❑ Yes ❑ No
for which the lagoon was designed.
8.
*N/A Will be done and on rile by April 24, 2004
A copy of the Annual Sludge Survey Form for this facility is attached to the Certification.
❑ Yes ❑ No
*NIA Will be done and on file by April 24, 2004
9.
Annual soils analysis were performed on each field receiving animal waste during the
9--Yes ❑ No
past calendar year.
10.
Soil pH was maintained as specified in the permit during the past calendar Year?
Yes ❑ No
11.
All required monitoring and reporting was performed in accordance with the facility's
Yes ❑ No
permit during the past calendar year.
12.
All operations and maintenance requirements in the permit were complied with during
Yes ❑•':o
the past calendar year or, in the case of a deviation, prior authorization was received
from the Division of Water Quality.
13.
Crops as specified in the CAWMP were maintained during the past calendar year on all
Yes ❑ No
sites receiving animal waste and the crops grown were removed in accordance with
the facility's permit.
14.
All buffer requirements as specified on the permit and the CAWMP for this facility were
[.'Yes ❑ No
maintained during each application of animal waste durinj&the past calendar year.
"I certify under penalty of law that this document and all attachments were prepared under my direction or
supervision in accordance with a system designed to assure that qualified personnel properly gather and
evaluate the information submitted. Based on my inquiry of the person or persons who manage the system, or
those persons directly responsible for gathering the information, the information submitted is, to the best of my
knowledge and belief, true, accurate, and complete. I am aware that there are significant penalties for
submitting false information, including the possibility of fines and imprisonment for knowing violations."
Signature of Operator in Charge
(if different from Permittee)
Date
-a o y
Date

Waste Management Plan Changes
Facility 'I ^ 18 r Farm C30,7 z
RECEIVED
JUL 01 2004
ON - FAYEiMIU FMOML O
This farms Waste Management Plan has made the following changes:
Crop changes
❑ Wetted Acres
❑ Increased Acreage
Decreased Acreage
❑ Changed Irrigation Design
❑ Change in Farm type
Lg--Plan based on 3 Years On Farm Records
❑ Other
Comments:
�-Z,�-o
Date

Murphy -Brown, LLC
Grower(s):
Farm Name:
06/29/2004 2822 Hwy 24 West
P.O. Box 856
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Murphy -Brown, LLC
3092
County: Bladen
Farm Capacity:
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish 8000
Storage Structure:
Storage Period:
Application Method:
Anaerobic Lagoon
>180 days
Irrigation
The waste from your animal facility must be land applied at a specked rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, A tons, etc.):
Capacity —Type Waste Produced per Animal Total
Farrow to Wean
3212 gallyr
gallyr
Farrow to Feeder
4015 gallyr
gallyr
Farrow to Finish
10585 gallyr
gallyr
Wean to Feeder
223 gallyr
gallyr
8000
Feeder to Finish
422.100 all r
3,376,843 gall r
Total 3,376,843 gall r
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (Ibs
Capacity T e Nitrogen Produced per Animal Total
Farrow to Wean
5.4 Ibslyr
Ibslyr
Farrow to Feeder
6.5 Ibslyr
Ibslyr
Farrow to Finish
26 Ibslyr
Ibslyr
Wean to Feeder
0.48 lbslyr
Ibslyr
8000
Feeder to Finish
1.057 Ibslyr
8,459 Ibslyr
Total 8,459 Ibslyr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARti
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 54.94
Total N Required 1 st Year: 16344.8
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops 16,344.80
Total Nitrogen Produced by Farm 8,459.00
Nitrogen Balance for Crops: (7,885.80)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2 of 8

Reception Area Specifications
Tract Field Irrigated Soil lot Crop Time to 1st Crop 1st Crop Lbs NIAc Lbs N Total Lbs N
Acreage Type Code Apply Yield ibs NlUnit Residual fAc Utilized
2nd Crop Time to 2nd Crop 2nd Crop Lbs NlAc Lbs N Total The N
Coda Apply Yield Ibs NlUnit Residual IAc Utilised
Total
Lbs NIAc
Total lbs N
Utilized
1498
2A
1.79
Wa ram
B
Mar -Se 1
5.5
43.25
237.875
425.7963
L
Sept -Apr
1
50
50
89.5
287,875
515.2963
2B
1.42
Wa ram
B
Mar -Set
5.5
43.25
237.875
337.7825
. L
Se hA r
1
50
50
71
287,876
408.7825
3
2.87
Wa ram
S
Mar -Set
5.5
43,25
238
682.7013
K
Sept -Apr
1
50
50
143.5
297,875
826.2013
4
2.73
Wa ram
B
Mar-Sepi
5.5
43.25
237.875
649.3988
K
Sept -Apr
1
50
50
135.5
287,875
785.8988
5
1.99
Wa ram
B
Mar -Set
5.5
43.25
237.875
473.3713
L
Sept -Apr
1
50
50
99.5
287.875
572.8713
6
1.45
Wa ram
B
Mar -Set
5.5
43.25
1
237.875
344.9188
K
Sept -Apr
1
50
50
72.5
287.875
417.4188
7
5.31
Wa ram
B
Mar -Set
5.5
43.25
237.875
1263.116
K
Sept -Apr
1
50
50
265.5
287.875
1528,616
8
5.27
Wa ram
B
Mar -Set
5.5
43.25
237,875
1253.601
K
Sept -Apr
1
50
50
263.5
287.875
1517,101
9
5.55
Wa ram
B
Mar -Set
5.5
43.25
237.875
1320.206
K
Sept -Apr
1
50
50
277.5
287.875
1597.706
10
2.47
Wa ram
8
Mar -Set
5.5
43.25
237.875
587.5513
K
I Se t-A r
1
50
50
123.5
287.875
711.0513
11
2.43
Norfolk
B
Mar-Sepi
6.5
43.25
281.125
683.1338
K
Se t-A r
1
50
50
121.5
331.125
804.6338
12
4.61
Norfolk
B
Mar -Sat
6.5
43.25
281.125
1295.986
K
Sept -Apr
1
50
50
230.5
331,125
1526.486
13
5,19
Goldsboro
B
Mar -Set
6.5
43.25
281.125
1459.039
K
Se t-A r
1
50
50
259.5
331.125
1718.539
14
5.93
Wa rem
a
Mar -Set
5.5
43.25
237.875
1410.599
K
Se t-A r
1
50
50
296.5
287.875
1707.099
15
5.93
Wa ram
B
Mar -Set
5.5
43.25
237.875
1410.599
K
Sept -Apr
1
50
50
296.5
287.875
1707.099
Totals: 54.94 13597.8 2747 16344.8
3(a) of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized / unit yield
A
Barley
1.6 lbs N / bushel
B
Hybrid Bermudagrass - Grazed
50 lbs N 1 ton
C
Hybrid Bermudagrass - Hay
50 lbs N 1 ton
D
Com - Grain
1.25 lbs N / bushel
E
Corn - Silage
12 lbs N / ton
F
Cotton
0.12 lbs N I lbs lint
G
Fescue - Grazed
50 lbs N / ton
H
Fescue - Hay
50 lbs N 1 ton
I
Oats
1.3 lbs N 1 bushel
J
Rye
2.4 lbs N / bushel
K
Small Grain - Grazed
50 Ibs N / acre
L
Small Grain - Hay
50 lbs N 1 acre
M
Grain Sorghum
2.5 lbs N I cwt
N
Wheat
2.4 lbs N I bushel
O
Soybean
4.0 lbs N / bushel
P
Pine Trees
40 lbs N / acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PAN/ rlanimal Farm TotaUyr
Farrow to Wean 0.84
Farrow to Feeder 1
Farrow to Finish 4.1
Wean to Feeder 0.072
8000 Feeder to Finish 0.36 2880
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 2880 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 14400 pounds of plan)
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 48 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 115.2 acres of land_ Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
"This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste-
5 of 8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract Hydrant
Type
Crop
inlhr
*inches
1498 2A
Wagram
B
0.6
1
2B
Wagram
B
0.6
1
3
Wagram
B
0.6
1
4
Wagram
B
0.6
1
5
Wagram
B
0.6
1
6
Wagram
B
0.6
1
7
Wagram
B
0.6
1
8
Wagram
B
0.6
1
9
Wagram
B
0.6
1
10
Wagram
B
0.6
1
11
Norfolk
B
0.5
1
12
Norfolk
B
0.5
1
13
Goldsboro
B
0.4
1
14
Wagram
B
0.6
1
15
Wagram
B
0.6
1
6 of 8

Additional Comments:
The bermuda rate in this plan is a combination of hay & graze. At least
half the Bermuda will be removed as hay.
7of8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: 3092
Owner: Murphy -Brown, LLC
Manager:
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff_
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Mu h -Brown, LLC
Signature:
Date
Name of Manager (if different from owner):
Signature: `"2/q
-d
Date
Name of Technical Specialist: Dawn Williamson
Affiliation: Murphy -Brown, LLC.
Address: 2822 Hwy 24 West, PO Drawer 856
Warsaw, NC 28398�
Telephone: [phone]
q �
Signature: I,n ; t-,�<;, ` 6 _z `
Date
8 of 8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited-
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recieving crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies-
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal_ Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3.of 3

ON -FARM RECORDS
Farm 30923
02A
69,455
57,080
187,265
02B
77,565
63,120
147,900
3
140,855
136,390
248,520
4
171,780
118,090
206,430
5
44,820
56,530
143,710
6
62,010
40,040
121,585
7
265.830
180.630
419,240
8
305,605
240,725
414.425
9
381,010
248,125
472,480
10
228,390
84,060
256,885
11
184,365
56,520
247,990
12
276,950
153,920
498,470
13
267,375
175,995
527,985
14
265,055
263,280
430,875
15
343,415
312,480
535,305
Total
3,084,480
2,186,985
4,859,065
Average annual volume applied
3,376,843
30923
Month
Year
PAN
April
2001
2.7
May
2001
3.1
June
2001
2.7
August
2001
1.8
October
2001
1.8
January
2002
2.4
February
2002
2.5
May
2002
3.0
June
2002
3.1
August
2002
1.5
October
2002
2.1
December
2002
2.6
February
2003
2.1
May
2003
2.6
August
2003
2.5
September
2003
1.9
November
2003
2.4
January
2004
3.3
April
2004
3.4
May
2004
2.6
Farm Average
2.51
Standard Deviation for waste analysis
Range of values included in average = 3.71/1.31
Total Lb. PANIYear m 8,459
.48 "
1.2024

Facility
Waste Management Plan Changes
1)?- zr(,
Farm i,Z ze-
RECEIVED
JUL 01 2004
00-FAYEtiE— E01011LOFRGE
This farms Waste Management Plan has made the following changes:
❑ Crop changes
❑ Wetted Acres
❑ Increased Acreage
❑ Decreased Acreage
❑ Changed Irrigation Design
❑ Change in Farm type
❑ Plan based on 3 Years On Farm Records
❑/Other
Comments:
S
(o --Z -o
Date

Murphy -Brown, LLC
Grower(s):
Farm Name:
06121 /2004 2822 Hwy 24 West
P.O. Box 856
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Murphy -Brown, LLC
Ezzell
Coun : Sampson
Farm Capacity:
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish 2844
Storage Structure:
Storage Period:
Application Method:
Anaerobic Lagoon
>180 days
Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, A tons, etc.):
Capacity Type Waste Produced per Animal Total
Farrow to Wean
3212 gallyr
gallyr
Farrow to Feeder
4015 gallyr
gal/yr
Farrow to Finish
10585 gallyr
gallyr
Wean to Feeder
223 gallyr
gallyr
2844
Feeder to Finish
986 all r
2,804,184 gallyr
Total 2,804,184 gallyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (Ibs
Capacity _____Type Nitro en Produced per Animal Total
Farrow to Wean
5.4 Ibs/yr
Ibs/yr
Farrow to Feeder
6.5 Ibs/yr
Ibs/yr
Farrow to Finish
26 Ibs/yr
Ibs/yr
Wean to Feeder
0.48 Ibs/yr
Ibs/yr
2844
Feeder to Finish
2.3 Ibs/yr
6,541 Ibs/yr
Total 6,541 Ibs/yr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARN
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 69.64
Total N Required 1 st Year: 12243.821
Total N Required 2nd Year: 9743
Average Annual Nitrogen Requirement of Crops 10,993.41
Total Nitrogen Produced by Farm 6,541.20
Nitrogen Balance for Crops: (4,452.21)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2of8

Reception Area Specifications
Tract Field irrigated -Soll let Crop Timato IstCrop istCrop LbsN/Ac LbsN
Acreage 1XF2 Code AppIj Yield lbs_NfUnit_Residual Utilized_
_
_IAc
■��®���©�
.,
®®o�©gin®��o��
3(a) of 8

SpecificationsReception Area
Tract Field Irrigated Soil 1 at Crop Tirrm to ISICrop IatCrGp Lb*N/Ac Lbs N Total Ibs IN
age
ield-
Typo Code_Apply_
W.17MR
_
_
_
3(b) of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen_
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized / unit yield
A
Barley
1.6 lbs N / bushel
B
Hybrid Bermudagrass - Grazed
50 lbs N / ton
C
Hybrid Bermudagrass - Hay
50 lbs N / ton
D
Corn - Grain
1.25 lbs N 1 bushel
E
Corn - Silage
12 lbs N / ton
F
Cotton
0.12 lbs N / lbs lint
G
Fescue - Grazed
50 lbs N / ton
H
Fescue- Hay
50 lbs N / ton
I
Oats
1.3 lbs N / bushel
J
Rye
2.4 lbs N 1 bushel
K
Small Grain - Grazed
50 lbs N 1 acre
L
Small Grain - Hay
50 lbs N / acre
M
Grain Sorghum
2.5 lbs N / cwt
N
Wheat
2.4 lbs N 1 bushel
O
Soybean
4.0 lbs N 1 bushel
P
Pine Trees
40 lbs N 1 acre 1 yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PANT r/animal Farm Totall r
Farrow to Wean 0.84
Farrow to Feeder 1
Farrow to Finish 4.1
Wean to Feeder 0.072
2844 Feeder to Finish 0.36 1023.84
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 1023.84 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 5119.2 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 17 acreas of land. If you apply the sludge
to com at a rate of 125 pounds per acre, you will need 40.9536 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal_
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
"This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5of8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract
Hydrant
Type
Crop
inlhr
*inches _
12073
1
Blanton
C
0.35
1
2
Blanton
C
0.35
1
3
Goldsboro
D
0.4
1
4
Wagram
D
0.6
1
5
Blanton
D
0.35
1
6
Blanton
C
0.35
1
7
Lynn Haven
WLHab
0.65
1
8
Lynn Haven
WLHab
0.65
1
9
Blanton
D
0.35
1
10
Blanton
D
0.35
1
11
Blanton
D
0.35
1
12
Blanton
D
0.35
1
7511
subl
Blanton
C
0.35
1
7511
sub3
Blanton
D
0.35
1
7511
sub4
Lynn Haven
WLHab
0.65
1
6of8

Additional Comments:
All small grain overseed and the wildlife lanting is optional for this plan.
Producer may plant watermelons on row crop land every three years.
PAN application on Watermelons is 40 Ibslacre up to 30 days pre -plant.
This will be followed by wheat to satisfy PAN balance for the year.
Subfield acreage will be included when irrigating with an aerway machine.
Aerway acres are optional.
7of8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: Ezzell
Owner: Murphy -Brown, LLC
Manager:
Owner/Manager Agreement:
Itwe understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Murphy -Brown, LLC
Signature:
Date
Name of Manager (if different from owner):
Signature: S4�ew*z r-o 4
Date
Name of Technical Specialist:
Dawn Williamson
Affiliation:
Murphy -Brown, LLC.
Address:
2822 Hwy 24 West, PO Drawer 856 _
_
Warsaw, NC 28398
Telephone:
[phone]
Signature:
Z_ pt
Date
8of8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recieving crop type, or available land.
Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells_
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist'. Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2of3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site_
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years_
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3of3

13Oc—
State of North Carolina
Department of Environment,
Health and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
A. Preston Howard, Jr., P.E., Director
Jimmy Vinson
Farah 92
PO Box 487
Warsaw NC 28398
Dear Jimmy Vinson:
AY15TA
IT 0
4�1
C)EHNR
June 23, 1997 RECEE—WED
JUN2S1997
FAYETTiEVILL 7
REG. OFFICE
Subject: Certificate of Coverage No. AWS090181
Farm 92
Swine Waste Collection, Treatment, Storage
and Application System
Bladen County
In accordance with your application received on June 18, 1997, we are forwarding this Certificate
of Coverage (COC) to Farm No. 09-181, authorizing the operation of an animal waste. collection,
treatment, storage and land application system in accordance with the State's General Permit (attached).
This approval shall consist of the operation of this system including, but not limited to, the management of
animal.waste from the Brown's of Carolina, Inc. Farm 92, located in Bladen County, with an animal
capacity of no greater than 8000 Feeder to Finish and the application to a minimum of 65.7 acres of land
as specified in the Certified Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until December 31, 2001. Pursuant to this
COC, you are authorized and required to operate the system in conformity with the conditions and
limitations as specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of
wastes to surface waters. An adequate system for collecting and maintaining the required monitoring data
and operational information must be established for this farm. Any increase in waste production greater
than the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to actual
increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the
General Permit or the CAWMP may result in the revocation of this COC. -
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This
request shall be made within 30 days of notification by the Division.
This COC is not automatically transferable. A name/ownership change application must be
submitted to the DWQ prior to a name change or change in ownership.
P_O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

If any parts, requirements, or limitations contained in this COC are unacceptable, you have the
right to apply for an individual non -discharge permit by contacting the engineer listed below for
information on this process. Unless such a request is made within 30 days, this COC shall be final and
binding.
The subject farm is located in the Fayetteville Regional Office. The Regional Office Water Quality
Staff may be reached at [phone]. If you need additional information concerning this COC or the
General Permit, please contact Andy Oakley at [phone] ext. (extension).
Sincerely,
Z_' —
G=/'_�/_� �
1ZA. Preston Howard, Jr., P.E.
cc: (Certificate of Coverage only for all cc's)
Bladen County Health Department
EFayetteville-Regional_Office, Water:Quality-Section
Bladen County Soil and Water Conservation District
Permit Files

State of North Carolina
Department of Environment,
Health and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
A. Preston Howard, Jr., P.E., Director
CERTIFIED MAIL
RETURN_RECEIPT REQUESTED
Brown's of Carolina
Farm 92
PO Box 487
Warsaw NC 28398
Farm Number: 09-181
Dear Brown's of Carolina:
May 14, 1997
0". MAI
17 0 0
C)EHNF=1
You are hereby notified that Farm 92, in accordance with G.S. 143-215.10C, must apply for
coverage under an Animal Waste Operation General Permit. Upon receipt of this letter, your farm has
thirty (30) days to submit the attached application and all supporting documentation. In accordance
with Chapter 626 of 1995 Session Laws (Regular Session 1996), Section 19(c)(2), any
owner or operator who fails to submit an application by the date specified by the
Department SHALL NOT OPERATE the animal waste system after the specified date.
Your application must be returned within thirty (30) days of receipt of this letter. Failure to submit the
application as required may also subject your facility to a civil penalty and other enforcement actions for
each day the facility is operated following the due date of the application.
The attached application has been partially completed using information listed in your Animal
Waste Management Plan Certification Form. If any of the general or operation information listed is
incorrect please make corrections as noted on the application before returning the application package. The
signed original application, one copy. of the signed application, two copies of a general location map, and
two copies of the Certified Animal Waste Management Plan must be returned to complete the application
package. The completed package should be sent to the following address:
North Carolina Division of Water Quality
Water Quality Section
Permits and Engineering Unit
Post Office Box 29535
Raleigh, NC 27626-0535
If you have any question concerning this letter, please call J R Joshi at [phone] extension
363 or Ed Buchan with the Fayetteville Regional Office at [phone].
Sincerely,
�vr A. Preston Howard, Jr., P.E.
cc: Permit File (w/o encl.)
Fayetteville Regional Office (w/o encl.)
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 101% post -consumer paper

State of North Carolina
Department of Environmer�����
and Natural Resources •
Division of Water Quality 7 199� f
,llll
James B. Hunt, Jr., Governor = .
Wayne McDevitt, Secretary A; ErrEV" .
A. Preston Howard, Jr., P.E_, DireGtpr,(3r—F1C
r_- NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NAruRAL RESOURCES
June 26, 1998
Brown's of Carolina, Inc.
Farm 92
PO Box 487
Warsaw NC 28398
Subject: Reissuance of Certificate of Coverage
No.AWS090181
Farm 92
Swine Waste Collection, Treatment, Storage and
Application System
Bladen County
Dear Brown's of Carolina, Inc.:
The Division of Water Quality modified the Swine Waste Operation General Permit originally issued to
this facility on June 23, 1997. In accordance with the issuance of the revised General Permit, we are
forwarding this Certificate of Coverage (COC) to Brown's of Carolina, Inc., authorizing the operation of
the subject animal waste collection, treatment, storage and land application system in accordance with
General Permit AWG100000. This approval shall consist of the operation of this system including, but
not limited to, the management of animal waste from the Farm 92, located in Bladen County, with an
animal capacity of no greater than 8000 Feeder to Finish and the application to land as specified in the
Certified Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003, and shall hereby void
COC No AWS090181 dated June 23, 1997. The COC shall hereby incorporate by reference any specific
conditions of the previous COC issued to this facility. The purpose of this COC is to allow coverage
under the revised General Permit. Please review the revised General Permit (enclosed) and pay
particular attention to Condition II.10 regarding tree removal from lagoon embankments, Condition III .1
regarding inspection frequency of the waste treatment, storage and collection system and Condition III.6
regarding notification requirements for system failures, spills and emergencies. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations
as specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the
General Permit or the CAWMP may result in the revocation of this COC, or penalties in accordance
with NCGS 143-215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive
relief.
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 5o% recycled/ 10% post -consumer paper

Certificate of Coverage AWS090181
Farm 92
Page 2
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This
request shall be made within 30 days of notification by the Division.
This COC is not automatically transferable. A name/ownership change application must be
submitted to the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the
right to apply for an individual non -discharge permit by contacting the engineer listed below for
information on this process. Unless such a request is made within 30 days, this COC shall be final and
binding.
The subject farm is located in the Fayetteville Regional Office. The Regional Office Water
Quality Staff may be reached at [phone]. If you need additional information concerning this
COC or the General Permit, please contact Katharine Keaton at [phone] ext. 533.
Sincer ,
A. Preston Howard, Jr., P.E.
cc: (Certificate of Coverage only for all cc's)
Bladen County Health Department
Fayetteville Regional Office, Water Quality Section
Bladen County Soil and Water Conservation District
Permit File

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
Brown's of Carolina, Inc.
Farm 92
PO Box 487
Warsaw NC 28398
Dear Brown's of Carolina, Inc.:
1fflW?W'JIT
•
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONmF-m-r AND NATURAL RESOURCES
December 30, 1999
10 2000
FAYUTEvILLE
AEG, CFFICE
Subject: Fertilizer Application Recordkeeping
Animal Waste Management System
Facility Number 9-181
Bladen County
This letter is being sent to clarify the recordkeeping requirement for Plant Available Nitrogen (PAN)
application on fields that are part of your Certified Animal Waste Management Plan.
In order to show that the agronomic loading rates for the crops being grown are not being exceeded, you
must keep records of all sources of nitrogen that are being added to these sites. This would include nitrogen
from all types of animal waste as well as municipal and industrial sludges/residuals, and commercial fertilizers.
Beginning January 1, 2000, all nitrogen sources applied to land receiving animal waste are required to
be kept on the appropriate recordkeeping forms (i.e, IRR1, IRR2, DRY], DRY2, DRY3, SLUR I, SLUR2,
SLDl, and SLD2) and maintained in the facility records for review. The Division of Water Quality (DWQ)
compliance inspectors and Division of Soil and Water operation reviewers will review all recordkeeping during
routine inspections. Facilities not documenting all sources of nitrogen application will be subject to an
appropriate enforcement action.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Ms. Sonya Avant of the
DWQ staff at [phone] ext. 571.
Sincere
Kerr T. Stevens, Director
Division of Water Quality
cc: Fayetteville Regional Office
Bladen County Soil and Water Conservation District
Facility File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirnmtive Action Employer 50% recycled/10% post -consumer paper

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Brown's of Carolina, Inc.
Farm 92
PO Box 487
Warsaw NC 28398
Dear Brown's of Carolina, Inc.:
IT
4 • • 2
IV
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
December 6,1999
DEc 1 J 1999
FAYETTEVILLE
REC. OFFICE
Subject: Conditional Approval
Animal Waste Management System
Facility Number 9-181
Bladen County
Our records indicate that your facility was conditionally certified in order to fulfill the requirements.
of completion of your Certified Animal Waste Management Plan Certification. This letter is to inform you
of your unresolved conditional approval status_ Any facility receiving a conditional approval must notify
Division of Water Quality (DWQ) in writing within 15 days after the date that the work needed to resolve the
conditional certification has been completed. Any failure to notify DWQ as required, subjects the owner to
an enforcement action. As of December 6, 1999, we have no record of any information from you, advising
us of the status of your conditional approval. Therefore, please fill out the attached form and have your
technical specialist and landowner sign the form in the appropriate areas.
The completed form must be submitted to this office on or before 45 days of receipt of this letter.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or liability
for failure to provide DWQ with proper notification of your conditional certification status or possible failure
to comply with the requirement to develop and implement a certified animal waste management plan by
December 31, 1997.
If you have any questions regarding this letter, please do not hesitate to contact me at [phone]
extension 571.
Sincerely,
Sonya L. Avant
Environmental Engineer
cc: Fayetteville Regional Office
Bladen County Soil and Water Conservation District
Facility File
1617 Mail Service Center. Raleigh, forth Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Airirmative Action Employer 50% recycled110% post -consumer paper

State of North Carolina
Department of Environment
and Natural Resources
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Brown's of Carolina, Inc.
Farm 92
PO Box 487
Warsaw NC 28398
Dear Brown's of Carolina, Inc.:
0 •
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
September 1, 2000 R EC E E D
SEP 1 1 2000
FAYETTEVILLE
REG. OFFICE
Subject: Notification for Wettable Acre Determination
Animal Waste Management System
Farm 92
Facility Number 9-181
Bladen County
A letter dated January 15, 1999 was sent to advise you about concerns associated with Certified Animal
Waste Management Plans and the method by which the irrigated acres within the plans were calculated. Only
the acres that are wetted can be credited in the waste management plan as receiving waste application. Any
acreage within the plan that can not be reached by waste application equipment can not be used as part of your
plan.
An evaluation by Jeffery Brown on 6/l /99 was made to review the actual number of acres at your facility
that receive animal waste during land application. The evaluation of your facility has yielded one of the
following two results as indicated by the box marked with an "X".
Category 1:
❑ The evaluation of your facility could not be completed due to a lack of information. Please
contact your Technical Specialist to assist in providing John Hasty the necessary
information to potentially exempt your facility from undergoing a complete wettable acre
determination. Please submit this information to John Hasty, at 225 Green Street, Suite
714, Fayetteville, NC 28301, within in 90 days of the receipt of this letter. If you have any
questions please contact John Hasty at [phone]. If within 90 days you are unable
to provide John Hasty with the information you are automatically required to complete
a Wettable Acre Determination as described by Category 2 below, within 180 days
of receipt of this letter.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Afrirmative Action Employer 50% recycled/10% post -consumer paper

Notification for Wettable Acre Determination
Animal Waste Management System
Page 2
Cate ory 2:
Your facility has been identified by the Department of Environment and Natural Resources
as a facility that may have overestimated the number of acres actually receiving animal
waste. Therefore, some or all of your fields may be exceeding the allowable loading rates
set in your Certified Animal Waste Management Plan.
In order to resolve this issue, please contact a designated Technical Specialist to have him
or her conduct a Wettable Acre Determination for your facility. The Technical Specialist must
be one that has been approved by the Soil and Water Conservation Commission to conduct
Wettable Acre Determinations. Many Technical Specialist with the N.C. Cooperative Extension
Service, the Soil and Water Conservation Districts, the Natural Resources Conservation
Service, and the Division of Soil and Water Conservation have received this special
designation. You may also contact a private Technical Specialist who has received this
designation, or a Professional Engineer.
All needed modifications to your Animal Waste Management System must be made and
the Wettable Acres Determination Certification must be returned to DWQ within the next
180 days. If the needed modifications are not made and if the form is not returned within the
required time, DWQ will be forced to take appropriate enforcement actions to bring this.facility
into compliance. These actions may include civil penalty assessments, permit revocation,
and/or injunctive relief.
Once a Wettable Acre Determination has been completed, a copy of the attached Wettable
Acre Determination Certification must be submitted to the address listed on the form. Please
note that both the owner and the Technical Specialist must sign the certification. A copy of all
the Wettable Acre Determination documentation that applies to your Waste Utilization Plan
must be kept at your facility. DWQ and the Division of Soil & Water Conservation Staff will
review all documentation during their annual visit of your facility. An additional copy must by
kept on file at the local Soil & Water Conservation District Office. Please note that if you install
or modify your irrigation system, a designated Irrigation Specialist or a Professional Engineer
must also sign the Wettable Acre Determination Certification.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Sonya Avant of our
Central Office staff at [phone] ext. 571.
Sincerely,
Kerr T. Stevens
cc: Fayetteville Regional Office
Bladen County Soil and Water Conservation District
Facility File

Murphy -Brown LLB
F, a --- .-
FE i0 2003
Mr. Rawls,
PO Drawer 856
2822 Hwy. 24 West
Warsaw, NC 28398
Tel: [phone]
Fax: [phone]
The following farms within the Murphy -Brown, LLC system had plan
amendments made to extend pumping windows. The plan amendments are attached for
each farm.
Farm Name
3092
Squire
Facility Number
09-181
09-26
If there are any questions please let me know.
Regards,
Todd Rowe, CCA
Agronomist
Murphy -Brown, LLC

CAWMP AMENDMENT
3092
This amendment is intended to extend the pumping window on Bermuda through
September 15`}', 2003. The crop on the farm was found to be in good health and at a stage
that is receptive to Nitrogen application. Cron removal from the fields is expected to be
sufficient to receive PAN until September 15` , 2003. Warm temperatures and good
weather will contribute to growth and uptake of nutrients by the crop.
Owner, Murphy -Brown, LLC
Manager
Technical Specialist
O L b
Date
la 14 a�
Date
Date

CAWMP AMENDMENT
Squire
This amendment is intended to extend the pumping window on Bermuda through
September 15`h, 2003. The crop on the farm was found to be in good health and at a stage
that is receptive to Nitrogen application. Cro removal from the fields is expected to be
sufficient to receive PAN until September 15 , 2003. Warm temperatures and good
weather will contribute to growth and uptake of nutrients by the crop.
Owner, Murphy -Brown, LLC Date
Manager Date
P49I.Je- Ce-14 3
Technical Specialist Date

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek. P.E. Director
Division of Water Quality
December 1, 2006
CERTIFIED MAIL
RETURN RECEIPT REQUESTED ;
Brown's of Carolina LLC
Farm 92
PO Box 487 - ... r--
Warsaw, NC 28398
Subject: Application for Renewal of Coverage for Expiring NPDES General Permit
Dear Permittee:
Your facility is currently approved for operation under one of the Animal Waste Operation NPDES General Permits, which expire on
July 1, 2007. Due to changes in federal rules, facilities that do not discharge nor propose to discharge may choose whether or not to
retain coverage under an NPDES General Permit. Copies of the draft animal waste operation NPDES general permits and the State
Non -Discharge General Permits are available at htip://h2o.enr.state.nc,us/ans/afouldownloads.htm or by writing or calling:
NCDENR — DWQ Animal Feeding Operations Unit
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure our continued coverage under one of these two types of general permits, you must submit an application for permit
coverage to the Division. Enclosed you will find a 'Request for Certificate of Coverage Facility Currently Covered by an Expiring
NPDES General Permit.' The application form must be completed and returned by January, 2, 2007. Please note, you must include
two 2) copies of your most recent Waste Utilization Plan with the application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the draft general permits, the enclosed application, or any related matter please feel free to contact the
Animal Feeding Operations Unit staff at 919-733-3221.
Sincerely,
« F
If-t -
Ted L. Bush, Jr., Chief
Aquifer Protection Section
Enclosures
cc (w/o enclosures): Bladen County Soil and Water Conservation District
Fayetteville Regional Office, Aquifer Protection Section
AFO Unit Central Files - 090181
Brown's of Carolina LLC
Aquifer Protection Section 1636 Mail Service Center
Internet: www.ncwaterrrualitv.Qre Location: 2728 Capital Boulevard
An Equal OpportunitylAffinnabve Amon Employer- 50% Recycledl10% Post Consumer Paper
Raleigh, NC 27699-1636 Telephone:
Raleigh, NC 27604 Fax 1:
Fax 2:
Customer Service:
Po"r'thCarolina
(919) v vII&M11If
[phone]
[phone] .
[phone]