090155_CORRESPONDENCE_20171231

Murphy -Brown, LLC
Farm #28 (BOC)
PO Box 1139
Wallace, NC 28466
AU6 13
c RrC#nnl,'
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
August 11, 2008
Subject: Sludge Compliance Requirement Change
Dear Permittee:
Coleen H. Sullins Director
Division of Water Quality
In accordance with Condition Ill. 19 of State General Permit AWG 100000, your facility is
required to maintain compliance regarding sludge accumulation in your animal waste treatment
lagoon(s). As you know, the previous compliance limit was to have a minimum of four (4) feet
of treatment depth between the designed stop pump and the average elevation of the top of the
sludge blanket. This requirement was based on NRCS Standard No. 359, which was recently
modified.
As of July 2008, Standard No. 359 does not use the 4 -foot requirement. Sludge compliance is
now to be based on the sludge volume as a percentage of the total treatment volume. The revised
Standard states that sludge accumulation in the permanent treatment zone must be less than 50%
of the planned treatment volume. Also, there must be a minimum of 2.5 feet of liquid above the
sludge at the pump intake location. If either of these conditions is not met then sludge must be
removed or managed in accordance with an approved Plan of Action for Lagoon Sludge
Reduction (POA). A new sludge survey worksheet has been developed to calculate sludge and
treatment volumes to determine compliance.
Our records indicate that you have filed a Sludge POA for one or more of the lagoons at your
facility. Based on the changes to the sludge requirements in Standard No. 359, your lagoon(s)
may already be in compliance without any sludge removal. Using your lagoon design (or as -
built information) and current sludge survey measurements, complete the NEW sludge survey
worksheet. if you have any difficulty in locating or understanding your lagoon design
information, please contact your technical specialist or county Soil & Water office.
ow
KorthCarolina
�Natura!!y
Aquifer Protection Section 1636 Mail service Center Raleigh. NC 27699-1636 Telephone: [phone]?21
Internet: www_ncwaterquality.otg Location: 2728 Capital Boulevard Raleigh, NC 27604 Fax l: [phone]
Fax 2: [phone]
An Equal OpportunitylAlfirmabve Action Employer— 50°% Recyded110 % Post Consumer Paper

Send both sludge survey worksheets, OLD and NEW, to the address below if you feel that your
lagoon(s) is in compliance and wish to withdraw your POA. Our staff will review the
information and notify you of our decision.
NCDENR — DWQ Animal Feeding Operations Unit
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
If you have any questions about the new sludge requirement, sludge survey worksheet, or any
related matter please feel free to contact the Animal Feeding Operations Unit staff at 919-733-
3221.
Sincerely,
Keith Larick, Supervisor
Animal Feeding Operations Unit
Enclosures
cc (w/o enclosures): Bladen County Soil and Water Conservation District
Fayetteville Regional Office, Aquifer Protection Section
AFO Unit Central Files - AWS090155

July 1, 2007
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Coleen H. Sullins, Director
Division of Water Quality
Murphy -Brown, LLC
Farm #28 (BOC) �� f 7 w: -r
PO Box 85b
Warsaw, NC 28398
Subject: Certificate of Coverage No. AWS090155
Farm #28 (BOC)
Animal Waste Management System
Bladen County -
Dear Murphy -Brown, LLC:
In accordance with your application received on 1 I -Jun-07, we are hereby forwarding to you this
Certificate of Coverage (COC) issued to Murphy -Brown, LLC, authorizing the operation of the subject
animal waste management system in accordance with General Permit AWGI00000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management
Plan (CAWMP) for the Farm #28 (BOC), located in Bladen County, with an animal capacity of no greater
than the following swine annual averages:
Wean to Finish: 0 Feeder to Finish: 0 Boar/Stud: 0
Wean to Feeder: 0 Farrow to Wean: 4000 Gilts: 0
Farrow to Finish: 0 Farrow to Feeder: 0
If this is a Farrow to Wean or Farrow to Feeder operation, there may also be one boar for each 15 sows.
Where boars are unneccessary, they may be replaced by an equivalent number of sows. Any of the sows
may be replaced by gilts at a rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009 and replaces the NPDES
COC issued to this facility with an expiration date of July 1, 2007. You are required to continue
conducting annual surveys of sludge accumulation in all lagoons at your facility; the one-year extension
in Condition M.19 does not apply.
Pursuant to this COC, you are authorized and required to operate the system in conformity with the
conditions and limitations as specified in the General Permit, the facility's CAWMP, and this COC. An
adequate system for collecting and maintaining the required monitoring data and operational information
must be established for this facility. Any increase in waste production greater than the certified design
capacity or increase in number of animals authorized by this COC (as provided above) will require a
modification to the CAWMP and this COC and must be completed prior to actual increase in either
wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Enclosed for your convenience is
a package containing the new and revised forms used for record keeping and reporting. Please pay
careful attention to the record keeping and monitoring conditions in this permit.
Aquifer Protection Section 1636 Mail Service Center
Internet: www.ncwateroualitv.oM Location: 2728 Capital Boulevard
An Equal OpportunitylAffirmative Action Employer -50% Recycled l O% Post Consumer Paper
Pec) Carolina
,11�murali'm
Raleigh, NC 27699-1636 Telephone: [phone]
Raleigh, NC 27604 Fax 1: [phone]
Fax 2: [phone]
Customer Service: [phone]

If your Waste Utilization Plan has been developed based on site-specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current MRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 02T .0111(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100 -foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Per 15A NCAC 02T .1306, any containment basin, such as a lagoon or waste storage structure, shall
continue to be subject to the conditions and requirements of the facility's permit until closed to NRCS
standards and the permit is rescinded by the Division.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Aquifer Protection staff may be reached at 910-433-3300. If you need additional information concerning
this COC or the General Permit, please contact the Animal Feeding Operations Unit staff at (919) 733-
3221.
Sincerely,
for Coleen H. Sullins
Enclosures (General Permit AWG 100000, Record Keeping and Reporting Package)
cc: (Certificate of Coverage only for all cc's)
Bladen County Health Department
Bladen County Soil and Water Conservation District
Fayetteville Regional Office, Aquifer Protection Section
AFO Unit Central Files
Permit File AWS090155

State of North State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
,tames B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
Mr. Jimmy Vinson
Brown's of Carolina, Inc.
P O Box 487
Warsaw NC 28398
Dear Mr. Vinson
D E N F�
February 26, 1998
RECEIVED
MAR 1 6 1998
FAYMEVUE
REG. OFFICE
SUBJECT: Acknowledgment receipt letter
' (34C -W29
Farm # 09-155
Case No. DD 97-008 and OP 96=004
Bladen_County, and Wlinilgounty,
This letter is to acknowledge receipt of check No. 076037 in the amount of $7,908.25
received from Carroll's Foods on February 11, 1998.
This payment satisfies in full the civil penalty levied against in the matter
of cases DD 97-008 and OP 96-004 and these cases have been closed. Payments of these
penalties in no way precludes further action by this Division for future violations of the State's
environmental laws.
If you have any questions please don't hesitate to call Shannon Langley at [phone],
extension 581.
SL/te
cc:
Fayetteville Regional Office
Wilmington Regional Office
Enforcement/Compliance Files
Central Files
Sincerely, /'
f,
Dennis R. Ramsey, Assistant Chief
Non -Discharge Branch
P.O. Sox 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

State of North State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
Mr. Jimmy Vinson
Brown's of Carolina, Inc.
P O Box 487
Warsaw NC 28398
RECEIVED"
MAR 2 3 1998
FAYc'-TTEvILLE
REG. OFFICE
Dear Mr. Vinson
A F441 0
D E N Fi
RECEIVEtD
February 26, 1998 N.C. Dept. of Ei-NR
MAR 13 1998
Winston—saiem
SUBJECT: Acknowledgment receipt letter
Carroll's Foods, Inc.
Farm # 09-155
Case No. DD 97-008 and OP 96-004
Bladen--CottyM.Duplin: County
This letter is to acknowledge receipt of check No. 076037 in the amount of $7,908.25
received from Carroll's Foods on February 11, 1998.
This payment satisfies in full the civil penalty levied against Carroll's Foods in the matter
of cases DD 97-048 and OP 96-004 and these cases have been closed. Payments of these
penalties in no way precludes further action by this Division for future violations of the State's
environmental laws.
If you have any questions please don't hesitate to call Shannon Langley at [phone],
extension 581.
Svte
W40
cFayett3eville-Regional-Of49e- r
Wilmington Regional Office
Enforcement/Compliance Files
Central Files
Sincerely, �.
1Z 7
Dennis R. Ramsey, Assistant Chief
Non -Discharge Branch
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

State of North Carolina
Department of Environment,
Health and Natural Resources
James B. Hunt, Jr., Governor
Jonathan B; Howes, Secretary
Brown's of Carolina Inc
Farm #28
PO Box 487
Warsaw NC 28398
T L ?WA
EDF-=HNR
November 12, 1996
SUBJECT: Operator In Charge Designation
Facility: Brown's of Carolina Farm #28
Facility ID;: 9-155
Bladen County
Dear Fane Owner.
RECEIVED
NOV f 21596'
FHYME/ILLE
RFr,, OFFICE
Senate Bill 1217, An Act to Implement Recommendations of the Blue Ribbon Study
Commission on Agricultural Waste, enacted by the 1996 North Carolina General Assembly,
requires a certified operator for each animal waste management system that serves 250 or more
swine by January 1, 1997. The owner of each animal waste management system must submit a
designation form to the Technical Assistance and Certification Group which designates an
Operator in Charge and is countersigned by the certified operator. The enclosed form must be
submitted by January 1, 1997 for all facilities in operation as of that date. Failure to designate a
certified operator for your animal waste management system is a violation of 15A NCAC 2H
.0224 and may result in the assessment of a civil penalty.
If you have questions concerning operator training or examinations for certification, please
contact your local North Carolina Cooperative Extension Service agent or our office.
Examinations have been offered on an on-going basis in many counties throughout the state for
the past several months and will continue to be offered through December 31, 1996.
Thank you for your cooperation. if you have any questions concerning this requirement please
call Beth Buffington or Barry Huneycutt of our staff at 9191733-0026.
Sincerelv,
A. Preston Howard, Jr., rector
Division of Water Quality
Enclosure
cc: Fayetteville Regional Office
Water Quality Files
P.O. Box 27687. 14 FAX [phone]
Raleigh, North Carolina 27611-7687 fC An Equal Opportunity/Affirmative Action Employer
Voice 919-715-4100 50% recycled/ 10% post -consumer paper

Information contained in this database is from non agency sources and is considered unconfirmed,
Farm Emergency Call Form
Farm Number (} — -`S Date 9/20/2000
Farm Name BROWN'S OF CAROLINA # 28 Time :13
Owner First Name BROWN'S OF CAROLINA Call Number 1309
Owner Last Name
OO Reporting O Complaint
Source
GUS SIMMONS
Plan Due Date Date Plan Data Freeboan
Inches
(7 equals blank) Received Level OK
Breached
O Yes OQ NO
Freeboard Lagoons 14
9/22/2000
Depopulated
JOYes 0 NO
Freeboard Lagoon2
[?-
overflowed
O Yes 0 NO
LO Issue
O Yes 0 NO
Freeboard Lagoon3
PermissionToPump
O Yes 0 NO
Freeboard Lagoon4
?
inundated
O Yes 0 NO
Freeboard Lagoons
7
Flooded
10 Yes Q NO
Freeboard Lagoonfi ��
?
Pumping Equipment
O Yes 0 NO
Comments
REPOU-ENTERED-BY-PAULBAWLS ................... -....... ..........
REPQR.I. IA.F.AX............_........._.............._.................................................._......_..............._......._.........�.�.._........__.__..
PER FAX POA ON THE WAY.
........................................................................................................................................................................................................I..................__....
......................-------.---................................................................................................................-----.......------................------.........--..........I..................
............................ .............................. __......... ..................... .... ........ ............................. ................. ----....... ..... .......... ... -.................. ....................
................................ ......... .................... ........ .... .................. ........ ................................................. ..................... ................ W..... _.........................
_....................................................................................................................................................................................................................... ......

SEP -01-00 FRI 02:06 PM BROWN'S OF CAROLINA!
r, BROWN'S
OF CAROLINA
FaX
:r
FAX NO. 2961333 P. 01
4f
�6� X87q,
'HAS We 2MB-CKA7
910-29&ISW
910 -?98~6166— Fax
FA=Q�k\C�)- �c5`c, ��� pigao; Vk
t
3Zo: CC;
: M 1pr
❑ urgont Q For Review ❑ Please Continent ❑ Plom Re Rdcyeie
4 pumnl:ahfC� �#
SeptembefFl; 2000
Subject: Lagoon Levels Update
The fallowi ig lagoon is within the 19" of freeboard as of September, ;1; 2000.
�+ Farm # 28 16" y r
Farm # 13 16" <• .,
PON
Our plan n1 action is to apply land applications as soon as the rams s, side and the
11k:7�1s..
fields are no longer saturated. Please tali if you wish to discuss theseslagoons or the
actions underway to alleviate this high level_
GUS Simmons 910-296-1800 (Office)
Glenn Davis 910-296-1800 (Office)
91C�290-0�� (Mobile)
lil��xt#I�1�,. n
i4�0:9*1.x

r'; .. .
Pwyiv vreAlfi tJW (Fv�ij°rNvNr� ntyR FREEBOARD ATANiIWPZACi,MES
Facility Number:. i County:
Facility 8o G .4
Name:
CertMed Operator Name: Operator
4. Current liquid level(s) in inches as measured from the current liquid level In the lagoon to the
lowest point on the top of the dam for lagoons without spillways; and from the current liquid level
In the lagoon to the bottom of the spillway for lagoons with spillways.
Structure 7 Structure 2 Structure 3 Structure 4 Structure 5 Structure 6
Lagoon NameAdentifier OD): ! . i
Spillway (Yes or No):
Level (inches): 1Lp
2. Check all applicable items
Liquid level is w" the designed structural freeboard elevations of one or more structures.
Five and 30 day Plans of Action ars attached. Hydraulic and agronomic balances are within
acceptable rangosf
Liquid level is within the 25 year 24 hour atonn elevations for one or more structures. A 30 day
Plan of Action Is aftached. Agronomic balance is within acceptable range.
Waste is to be pud' ped and hauled to off site locations. Volume and PAN content of waste to
pumped and haul#d is reflected in section Ili table& Included within this plan is a fist of the
proposed sites with related facility number(s), number acres and receiving crop information.
Contact and secure approval from the Division of Water Quality prior to transfer of va3te
to a site not covered In the faculty's certified animal waste trianagerneat plan.
Operation will be partially or fully depopulated.
- attach a complete schedule with corresponding animal units and dates for depopulation
- if animals are to be moved to another permitted facility, provide facility number, lagoon
freeboard levels arid herd population for the receiving facliity
3. Earliest possible date to Yegin land application of waste:
r
I hereby codify that I have rev d the Information ffabad above and included within the attached Plan
of Action, and to the best of nrW knowledge and abMty, the information is accurate and correct.
QC Phone;
Facility OwneHManager (print)
PoA Cover Page 2121100

MAY. 5.2000 11:2311 ENVIROMMENTAL MGMT
Facility OwnerlManager {signature
Pall Cover Page 2121M
N0.959 P.319
Date: 9

PLAN OF ACTION (PoA) FOR HIGH FREEBOARD AT ANIMAL FACILITIES
30 DAY DRAW DOWN PERIOD
1. TOTAL PAN TO BE LAND APPLIED PER WASTE STRUCTURE
1. Structure Name/Identifier (ID): BOC #28 AWS090155
2. Current liquid volume in 25 yr./24 hr. storm storage & structural freeboard
a. current liquid level according to marker 16.0 inches
b. designed 25 yr./24 hr. storm & structural freeboard 20.4 inches
c. line b - line a Cinches in red zone) = 4.4 inches
d. top of dike surface area according to design
(area at below structural freeboard elevation) 320716 ft'
e. line c112 x line d x 7.48 gallons/ft3 879617 gallons
3. Projected volume of waste liquid produced during draw down period
f. temporary storage period according to structural design 180 days
g. volume of waste produced according to structural design 422966 ft3
h. current herd # 4000 certified herd #1 4000
actual waste produced = current herd # x line g =
certified herd #
i. volume of wash water according to structural design
j. excess rainfall over evaporation according to design
k. (lines h + i + j) x 7.48 x 30 days/line f=
4. Total PAN to be land applied during draw down period
I. current waste analysis dated 7121/00
m. ((lines e + k)/1000) x line I =
REPEAT SECTION I FOR EACH WASTE STRUCTURE ON SITE.
(Click on the next Structure tab shown below)
PoA (30 Day) 2/21/00
422966 ft'
0 ft3
191333 ft'
765826 gallons
1.50 Ibs/1000 gal.
2468.2 lbs. PAN

11. TOTAL POUNDS OF PAN STORED WITHIN STRUCTURAL FREEBOARD AND/OR 25 YRd24
HR. STORM
STORAGE ELEVATIONS IN ALL WASTE STRUCTURES FOR FACILITY
1.
Structure ID: BOC #28 AWS090155
tine m =
2468.2 Ib PAN
2.
Structure ID:
line m =
Ib PAN
3.
Structure ID:
line m =
Ib PAN
4.
Structure ID:
line m =
lb PAN
5.
Structure ID:
line m =
lb PAN
6.
Structure ID:
line m =
lb PAN
n.lines 1+2+3+4+5+6= 2468.2 lb PAN
111. TOTAL PAN BALANCE REMAINING FOR AVAILABLE CROPS DURING 30 DAY DRAW DOWN
PERIOD. DO NOT LIST FIELDS TO WHICH PAN CANNOT BE APPLIED DURING THIS 30 DAY PERIOD.
o. tract #
p. field # q. crop
r. acres
s. remaining IRR- L TOTAL PAN u. applicatbn wuidaw'
2 PAN balance BALANCE FOR
(Iblacre) FIELD (lbs.)
column r x s
4737
F1 -H d10 Small Grain Grazed
1.78
75.00
133.5 Sept -April
4737
F1 -H d11 Small Grain Grazed
4.44
75.00
333.0 Sept -April
4737
F2 -H d12 Small Grain Grazed
5.84
75.00
438.0 Sept -April
4737
F2 -H d13 Small Grain Grazed
5.65
75.00
423.8 Sept -April
4737
F2 -H d14 Small Grain Grazed
4.27
75.00
320.3 Sept -April
4737
F2 -H d15A Small Grain Grazed
2.80
75.00
210.0 Se t -A riI
4737
F2 -H d15B Small Grain Grazed
1.95
75.00
146.3 Sept -April
4737
F3 -H d9 Small Grain Grazed
1.56
75.00
117.0 Sept -April
4737
F4 -H d8A Small Grain Grazed
3.03
75.00
227.3 Sept -April
4737
F4-Hyd8B Small Grain Grazed
4.02
75.00
301.5 Se t -A riI
4737
F5-Hyd2 Small Grain Grazed
4.93
75.00
369.8 Sept -April
4737
F5 -H d3 Small Grain Grazed
4.25
75.00
318.8 Sept -April
4737
F5 -H d4 Small Grain Grazed
3.32
75.00
249.0 Sept -April
4737
F5 -H d5 Small Grain Grazed
3.04
75.00
228.0 Se i -A riI
4737
F5 -H d6 Small Grain Grazed
1.33
75.00
99.8 Sept -April
4737
F5 -H d7 Small Grain Grazed
1.74
75.00
130.5 Se -A riI
4737
F6 -H d1 Small Grain Grazed
2.61
75.00
195.8 Sept -April
'State current crop ending application date or next crop application beginning date for available
receiving crops during 30 day draw down period.
v. Total PAN available for all fields (sum of column t) = 4242.0 Ib. PAN
IV. FACILITY'S PoA OVERALL PAN BALANCE
w. Total PAN to be land applied (line n from section II) = 2468.2 Ib. PAN
PoA (30 Day) 2121100

x. Crop's remaining PAN balance (line v from section Ill) = 4242.0 Ib. PAN
y. Overall PAN balance (w - x) _ -1774 ib. PAN
Line y must show as a deficit. if line y does not show as a deficit, list course of action here including pump and
haul, depopulation, herd reduction, etc. For pump & haul and herd reduction options, recalculate new PAN
based on new information. If new fields are to be included as an option for lowering lagoon level, add these
fields to the PAN balance table and recalculate the overall PAN balance. If animal waste is to be hauled to
another permitted facility, provide information regarding the herd population and lagoon freeboard levels at the
This farm is currently in a high freeboard status due to the fad that the irrigation system is being converted
from traveler pulls to solid set. While this conversion is in process, the fields onto which irrigation can be done
is limited due to new installation. As the installation progresses from field to field, the lagoon level will be
lowered by irrigating on the completed fields.
PoA (30 Day) 2/21 /00

SRP -01-00 FRI 02:06 Phi BROWN'S OF CAROLINA! FAX NO. 29131333
PiHoi€Wi°rovrAC, ;WW Fojr0n ud
Facility Number:
Facility ,
Name:
�� cr
P. 02
FREE130ARD ATANI1W,,:iVACi?,w4j$iES
County'.�.�'+
4
Certified operator Name: Cperato�,F
1, Current liquid level(s) in inches as measured from the current liquid level In the lagoon to the
lowest point on the top of the dam for lagoons without spillways; and fromlti'te current liquid level
In the lagoon to thy. bottom of the spillway for lagoons with spillways.
Structure I Structure 2 Structure 3 Structure d -ftuctura 5 Structure S
Lagoon NarneAdentifier (ID): ! _ �3 '
art;
Spillway (Yes or No):Na _ : rut: zl
2. Check all applicable items ,
Liquid leve is Mthip the designed structural freeboard elevations of one or more structures.
Firm and 30 day Plans of Action are attached. Hydraulic and agronornle balances are within
acceptable rangesi
✓ Liquid level is within the 25 year 24 hour storm elevations for one or more structures_ A 30 day
Plan oiAct"on is a' ched. Agronomic balance is within accepta uu
d1F kl�i�9
Wasta is te, be v .;
�� i' ' ped and hauled to off site locations. Volume and PAN onrl�t of wastes to
clumped ar.d hnul is reflected in section Iii tables. Included withln;3als pian is a ilst of the
proposed sites w related facility number(s), number acres aM Vrvp infmMlon.
Contact ar..d secure approval from the Division of Water OuaIIty` recti"tra transfer of waste
W a rite ncit eaverad In the facility's eardfled animal waste rmnegen*nt plan.
Cperabcn vfill be partially or fully depopulated.
-attach a ca3mplete schedule with corresponding animal units and dates ler depopulation
- if animals are to be moved to another permitted facility, provide faci ty number, lagoon
freeboard k,vels and herrn population for the receiving facility
3. Earliest passible date to Yegin land application of waste:
I hereby certify that I have reviewed the information listed above andlrtclui:s+d iirdfifis Ow attached Plan
of Action, and to tha best of my knowledge and ability, the information Is acaurate'u+d correct
rte'
%Phone:''''s
Facli%ty OwneNManager (print)
PoA Cover Page 213140

SEP -01-00 FRI 02:06 PM BROWN'S OF CAROLINA! FAX N0, 2961333
MRY. 5.220: II:Z?W vij{IRQNI'EMTI L MGMT NO 955 P. 3--9
/�,�/Cry ''r'_ i �iJ /�//-2�- Ja/�iz.�lc~i /fT-'i� i+.e•r.
Date:
FacHity CNMed Manager {signahtra} -
' F
"N�rC
PoA Corer lige 2121100
P. 03

SEP -01-00 FRI 02:07 PM BROWN'S OF CAROLINA! FAX NO. 2961333,",
PLAN OF ACTION (PoA) FOR HIGH FREEBOARD AT ANIMAL``FACILITIES
30 DAY DRAW DOWN PERIOD
I. TOTAL PAN TO 13E LAND APPLIED PER WASTE STRUCTURE raYr�-.ffaS
1. Structurc: Name/Identifier (11)). O #28 AWS090155
ARM,
2. C�;rrelll liquid volume in 25 yr./24 hr. storm storage & structural free i
r'
a. current liquid level according to marker 16.0 inches
b. designed 25 yr.124 hr. storm & structural freeboard 20.4 inches
c. line b - tinea (inches in red zone) 4.4 inches
d. top of dike surface area according to design
(area at below structural freeboard elevation) 320716 ft2
C. line ell x line d x 7.48 gallons/W 879617 gallons
3. Projected volume of waste liquid produced during draw down perCs?fi 3:
f. temporary storage period according to structural design 180 days
g. volurne of waste produced according to structural design
lit
422965 ft'
h. current herd # 4000 certified herd #1 40Q0
actual waste produced = current herd # x fine g 42.2966 ft3
certified herd #
i. volume of wash water according to stnictural design ;-4 }' 0 ft3
j. excess rainfall over evaporation according to desig 191333 ft3
3 ��_�
k. (lines h + i + j) x 7.48 x 30 days/line f= 765826 gallons
•r
4. Tolal PAN to be land applied during draw down period.14A:��';:-f�
I. current waste analysis dated 7/21100
m. (0incs e + k)11000) x line I =
REPEAT SECT€ON II FOR EACH WASTE STRUCTURE ON SITE.
(Click on the next Structure tab shown below)
PoA (30 Day) 2/21/00
P. 04
1.50 lbs/1000 gal.
2468.2 lbs. PAN

SEP -01-00 FRI 02:07 PM BROWN'S OF CAROLINA! FAX NO. 2961333 P. 05
.0
Il. TOTAL POUNDS OF PAN STORED WITHIN STRUCTURAL FREEBOARD Al11DI IR 26 YR./24
H.R. STORM STORAGE ELEVATIONS IN ALL WAST: STRUCTURES FOR FACILITY
1. Struc•tum., ID. BOC #28 AWS090155 line m,- •a f2468.2 lb PAN
2. Siruclurn ID: line m = Ib PAN
'h
3. Siructuro ID; line m = Ib PAN
f. Stmcture ID:
5. Structurc:ID:
6. Struclum ID:
n. lines I + 2 + 3 + 4 + 5 + 6 =
line m Ib PAN
line m = Ib PAN
line m, -t- Jb PAN
t,.
.. al'R4682 Ib PAN
lii. TOTAL PAN BALANCE REMAINING FOR AVAILABLE CROPS DURING 30 DAY DRAW DOWN
PERIOD. DO NOT LIST FIELDS TO WHICH PAN CANNOT BE APPLIED DURING -THIS 30 DAY PERIOD.
o. tracl # p. field # q_ crop
r. acres
s. remaining IRR- L TOTAL PAN U.SppucatjonwwoW
2 PAN balance BALANCE FOR
(]Macre) FIEW (Ibs)
colr�pi,
4737
F1 -l -I d10 Small Grain Grazed
1-78
7$.00 -� 4 MtO33:5 Se -A
rid
4737
F1 -1-I di i Srnall Grain Grazed
4.44
75.00
" 333.0 Sept -April
4737
1`2 -I -i 412 Small Grain Grazed
5.84
75.00
.x,,.438.0 Sept -April
4737
F24 -W13 Srnall Grain Grazed
5.65
75.
Kt-_ $A23.'8 Se Aril
4737
F2-F`yd14 Small Grain Grazed
4.27
75-00 = ` 1,320.3 Se -A
dl
4737
l=2 -H d15A Small Grain Grated
2.80
75.00
144 ,210.0 Sept -April
4737
F2-Hyd15B Small Grain Grazed
1.95
75.00
-' 146.3 Se -
lil
4737
F3-Hd9 Small Grain Grazed
1.56
75.00
7.0 Sept -April
4737
F4-Hyd8A Small Grain Grazed
3.03
75.00
227.3 Sept -A 41
4737
F4-Hyd8B Small Grain Grazed
4.02
75.00
301.5 Sep! -April
4737
F5 -H d2 Small Grain Grazed
4.93
75.00
369.8 Sept -April
4737
I=5--iyd3 Small Grain Grazed
4.25
75.00
318.8 Sept -April
4737
F5--ici4 Small Grain Grazed
3.32
75.00
249-0 Sept -April
4737
F5-1105 Small Grain Grazed
3.04
75.00
228.0 Sitpt-April
4737
1=5-1:de Small Grain Grazed
1.33
75.00
- 99.8 Se t -A
ril
4737
F5-1-1 d7 Small Grain Grazed
1.74
75.00
`"'130.5 Sep!-
ril
4737
F6-Ij d1 Small Grain Grazed
2.61
75,00,..�y1'95.8
Se -A
ril
'State current crop ending application datc Dr next crop application beginning date'fdr-Available
receiving crops tdurinq 30 day draw down period.
v. Total PAN available for all fields (sum of column t)
IV. FACILITY': PoA OVERALL PAN BALANCE
W. Total F'AN to be land applied (dine n from section 11)
PoA (30 Day) 2/21J0C
V;W4242.0 lb. PAN
..�2468.2 lb. PAN

SEP -01-00 FRI 02:07 PM BROWN'S OF CAROLINA! FAX NO. 298I333- P. 06
x, Crap's remaining PAN balance (line v from section III) = 4242.0 Ib. PAN
y. overaal PAN balance (w - x) = - j-1774 Ib. PAN
,f--T-�i�
to y must s,�ow a:i a deficit. If line y does not show as a deficit, list tours 'ot;a fiery Including pump and
ul, depopulation, herd reduction, etc. For pump & haul and herd reducti opii ermc'ulate new PAN
sed on new information. If new fields are to be included as an option for lowering lagoon level, add these
--
Ids to the PAN be fence table and recalculate the overall PAN balance. If aitlmn
.#e Is to be hauled to
other permitted facility, provide information regarding the herd population'and l7 bn freeboard levels at the
:eivin facisity�, " '
NRRATIVE.,
its farm is currently in a high freeboard status due to the fact that the irrigation sytWm is being converted
IM traveler pulls to solid set. White this conversion is in process, the fields -onto Alch irrigation can be done
limited due to new installation. As the installation progresses from field to field, the lagoon level will be
Yered by irrigating on the completed fields. .
l
-L
Pit
PoA (30 Day) 21211oo -jo" "
fir? AMA,

FEZ;- 2-00 WED fill PM BROWN
FAX NO. 91029161675
9 45S
EMERGENCY PLAN OF ACTION
Date: February 2, 2000
Producer: Brown's of Carolina, IncA
Farm: BOC 14910, 272 319 159 239 24S9 24NF, 94A, 94B9 28,
299 309 919 93A5 93B
The following steps will be used in our plan of action to lower and maintain the lagoon
lad at the aboye mhntlon d flims is a Ivy9l ft vivyido IN itruoural stability and retain the
25 year, 24 hour rainfall event.
Step 1: Monitor daily existing spray fields for a time to begin pumping.
P. 2
Step 2: Monitor daily freshwater use to minimize any waste that will contribute to lagoon levels.
Step 3: Monitor pits for additional storage time in the barns.
Step 4: Evaluate lagoon marker and top of dike elevations with technical specialist to ensure
accurate level determination.
Step 5: Read lagoon levels daily by accurate measuring device.
Step 6: If the previous steps do not provide satisfactory results, then hauling to another site.

SS Hwy 24 East
PO $mt 487
Wwww, NC 2WW-W7
Voice: [phone]
Fa)[ (910) 29"168
Fm
I 'd
BROWN'S
SOF CAROLINA
RMVED
F -EB 3 2000
FAYMEVILLE
REG. OFFICE
Toa ,.rJP✓ ,!d �J� _ Frorm
pages:
Phvewsf Dates
Re: CC1
El Vrgoat 0 For Review ❑ Please Conmeat ❑ Please R.Pry ❑ Please R*aycla
SL9 H016 'ON Xtld
S NMOH Wd { 1 :9 U3 00-Z -S33

01/07/2090 13:33 919-715-6048 DWO NON DISCHARGE BR PAGE 02/02
FACILITIES WITH HIGH FREEBOARD LEVELS AS OF January 7, 2000
Brown's of Carolina
I�
11/29/99
82-442
BOC Farm #10
15"
1213/99
82-442
BOC Farm #10
15"
11/29/99
82-340
BOC Farm #11
14"
12/3199
82-340
BOC Farm, 011
14"
11/29/999
82-341
BOC Farm #13
14"
12!3/99
82-341
BOC Farm #13
18"
11/29/99
9-155
BOC Farm #28
18"
(12/3/99
9-155
BOC Farm #28
20"
L
12!3/99
9-155
BOC Farm #28
20"
11/29/99
9-170
BOC Farm #30
10"
12/3/99
9-170
B OC Farm #30
14"
1129/99
78-85
BOC Farm #94B
14"
1213/99
78-85
BOC Farm #94B
14"
?
82-630
Jana Farms (BOC)
16"
Carroll's Foods, Inc.
FRO
p 9-45 Elden Hester (Carroll's)
Continental. Grain
FRO
12/6/99
1216/99
DRAFT
Mssf
82-478 + N & C Hogs, Inc. (CG) 14" Z�
82-478 N & C Hogs, Inc. (CG) 15"
Murphy Family Farms
FRO
12/22/99 82-312 Top Hogs (MM*
* Indicates facilities with high freeboard +ound by DWQ during inspections.
14"

OCT -04-00 WED 02:44 PH BROWN'S OF CAROLINA!
BROWNI
OF
CAROLINA
Fc17C
FAX Np�,,
M KWy 24 East
From:
Paws:
P. 01
Malec V )- I-V
J V'?
Mr M.
0 Urseat El For Review 0 Please Commant
67-
13 Plo=o Reply P18=0 Iblaycle
a Commwatc
och!M�
Subjcc.t: Lagoon Levels Update
, MV,
The fo!!uvving lagoons are no longer Within the 19"
of freeboard as of Se mber -00,
2000.
4P
Farm# 13 Yl
Farm# 29 21- — 1- 193
Farm # 30 21"
The folowin!) lagoon is no longer within the 19^
of Freeboard as of October 3, 2000.
Farm # 28 19 -
Gus Simmons 910-296-1800 (Office)
VrX .1
Glenn Davis 910-296-1800 (Office)
910-2. dbile)
Kevin Weston 910-296-1800 (Office)

I
I
I

JAN -26-90 FR1 $:52 FM BROWN S
FAX NO, 9102961675
F. 1
Weekly Lagoon
Level Status List; '�� '"��'`""" to `
_
Faun Nam
"MO&I Laval Reinfalltlnaml
Stales
91
-,,02
(18
0.5
:rte
;10
0.7
04
22
0.7
si
05
20
0.7
t
OB
28
0.7
07
20
0.7
08
20
0.7
0.7
IN REO ZONE!
10
20
0.t
11
22
0.6
12
22
0.7
1,6`
0.58
IN RED ZONEI
14
19-7
0.53
,
is
23
0.5
18N
25
0.5
16S
26
0.5
17F
ZG
0.5
0.5
-."-20
.18=
0.4
IN RED ZONEI
21
28
0.5
22
21
0.7
23
22
0.6
24N
20
0.6
-- 24S
1811
0.6
IN RED ZONEI
25F
22
0.7
204
V
6.7
-25 S
19
0.7
26
24
0.5
'27
22
0.6
q_ ass , 28?
•17
0.6
IN RED ZONEI
29
10
0.4
--- 30
a2
0.5
IN RED ZONEI
4
IQ`
0.7
34
24
0.4
35
23
0.5
81
35
0.7
82
35
0.5
90
23
0.5
- 91-
19
0.5
92
27
0.5
93A
20
0.4
_938.
16
0.4
IN RED ZONEI
-94A-
.16
0.6
IN RED ZONEI
-94B
17
0.8
IN RED ZONEI
GB1
30
0.7
GB2
38
0.7
SH
25
0.7
WP
25
0.7
FM&V. January 29. 2000 varmo Em000m ctW en6f ehss): 20.21 Pa20 1

oa --sr - I ,, e/
CV
Q
-d4 b ,• .h
-�- / 7t- s Il'
1161 r-,`° ,9/
rl-x�v "(-�
l �r
oe #-' Dog
D0'
5.8 -s(-
.(h � - rs
�t-E17
bl:�- 60
F
' O�v
,c1 --f,9

7aBROwm'S
CAROLINA
Demmber 30, 2996
Ed Buchan
Environmental En&M
Division of Water Quality
Wachovia Buil ft
Suite 714
FayettevMe, NC 28301-5043
Dear Mr. Buchan,
RECEIVEr)
JAN 6 1997,
t t
RM OFRCE
This letter is in response to the Notice of Deficiency for Brown's of Carolina, Inc. Farm 28
received on December 6. Due to the. storm events in the summer, this lagoon has been high and
within the 19 inch freeboard. Since your inspection on October 23, irrigation equipment
installation has been complete and a winter cover has been established. We are utilizing every
available pumping opportunity to lower this lagoon level. It is, however, stilt within the
freeboard.
Please contact me at [phone] if you have any additional questions.
40e
1l,,
7umnirmy Vinson
Environmental Resources, Mgr.
QROWKS of CAROLINA. INC.
303 EAST COLLEGE STREET - P.O. eox 487 - WARSAW. N.C. 20398.8407 - OFFICE: (910) 293-21111 - FAX -(910)2934726

WOW
elm Y�YIYWD
arle•trs �T u�
Cow.wwlsi �K
4�Wlorr, w. C.
a�)f�
Beco 348 ;Tn642
sun OF Nom CAHOLm
CXXWY OF KAM %ARAAWY �
MUS W,RA WY — made this the 14th day of October, 1994, by and
between the fDUcwing: DArrnc mcaLaM CAlFSEii., III, single,
hereinafter referred to as Grant= to PiFcm,S cF CRS1Qj. a, nc.,
hereinafter referred to as Grantee.
WITNESSETH•
That the Grantor, for and in consideration of the sum of TPN
1$10.00) DOaJAMS, and other good and valuable cmaiderations to that, in
hard paid by the Grwrtee, the receipt whereof is hereby a ow wledged,
have given, granted, bargained, sold and conveyed, and by t2neae prevents
do give, grant, bargain, veli, convey and confirm unto the Grantee,
tpi.
�ieirr heirs and/or suss= and assigns, prises in Mutes Creek
maad4, Bladen Qxmt:y, North Ournlinw, and more pnticularly described
as follows:
Those certain lands containing 254.40 &czas, mare or
less, as Shown on Survey for Mrs. !Margaret Clark,
prepared Deoedaes 12, 1988, by Stuart Gooden, Registered
Surveyor, and rworded in Plat Cabinet A-81, Page 812, in
the Office of the Register of Deeds of Bladen County,
which reouted map is made a part hereof by refexe nce for
greater certainty of description.
Subject to right of ray for Seaboard Coastline Railroad,
N.C. Highway 211 and power line right of way to Carolina
Power and light CmQany as shown on the aforesaid survey.
TO HAVE AMID 10 HOLD the above described premises, with all the
A 3 tenancw thereunto belonging, or in any wise appertaining, oto the
Grantee, their heirs and/or successors and assigns in fee siWle
forever.
And the Grantor covenant that they are seized of said prod ses in
fee, and have the right to convey the same in fee single; that said
Premises are free fran enmabranaes; and that they will warrant and
defend the title to the same against the lawful claisas of all persons
Il�7pI�pCVeI.
IN WIDaSS i IMMOF, the Grantor has herieanto set his hand and seal,
the day and year first
abtvE written.
2
IS£AI.}
i
gyN�t�(r DAISAS McQCgiN ✓
4 ,III
N
Prepared by. Alan I. Maynard
n �� _,y sY
• ;r
i
.{

k
say 348 643
STM CF NCM CAFQLma
COLWY OF BLADEN
.
I,
-D, 1: 1. � a Notary Public of said County, do
hereby O=UfT that UUM MOMEEN CMWMZ, Z11, persMally appeared
befare me this day and acknowleclqW the due examum of the fl=wPuv
instrument for the purposes dmweia described.
Witness my h. -d and mftrial aeni, this the Lq!L—_day of
1994. (.,Pt Pal—)
NCTAM PL9=C L)
Cw*.&&uw:
j-40 -
"
pUCLNOTA!!
STATE OF NUM CARM.M
0OL1?ry OF BIADEN
The foregoing certificate oflad a Notary
Public of North Carolina. be correct. This instrument
was presented forstration this _,Y�dy of _A J- , 1994,
at -9: 2�6 01 c 7 M., and duly r000rded in this Office of the
Register of Deeds of Bladen cmmty, Hm-th carouw, in Bock -W2 Page
•
Lq U6- W
REGISTER CF
4wim. RW.L5-nm OF
Azi
A

.,< <,d%jj l i i t.:arollna
Department of Environment,
_. Health and Natural Resources 4 • ,�
Fayetteville Reglonal Office
James B. Hunt, Jr., Governor
Jonathan B. Howes, SecretaryE)aHNF;Z
DIVISION OF WATER QUALITY
March 24, 1997
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Mr. Jimmy Vinson
Browns of Carolina, Inc.
P.O. Box 487
Warsaw, NC 28398
Subject: Notice of Recommendation for Enforcement
BOC 28 Swine Facility
Facility No. 09-155
Bladen County
Dear Mr. Vinson,
This letter is to notify you that the Fayetteville Regional Office
of the Division of Water Quality is considering sending a
recommendation for enforcement action' to the Director of the
Division of Water Quality. The recommendation concerns the
violation -by the BOC 28 Swine Farm on February 25, 1997 of your 2H
.0217 non --discharge permit, pusuant 15A HCAC 2H .0217.
If you have an explanation for this violation that you wish to
present, please respond to this office on or before March 19, 1997.
Your explanation will be reviewed and if an enforcement action is
still deemed appropriate, your explanation will be forwarded to the
Director with the enforcement package for his consideration.
If you have any questions concerning this matter, please contact me
at [phone].
Sincerely,
yl . �
Kerr T. Stevens
Regional Supervisor
cc: Sue Homewood -- Compliance Group
Central Files
Jachovia Building, Suite 714. Fayetteville � C FAX 91£?�4 "707
North Coroiina 2MI-5(A3 ` 0 An Equal OppoMmHy Aifimx t e Action Empioyer
Voice 9}0-4a6-15541 50% recycled/10% post-cortSimef paper

P._ 427 894 149
US PosW 5ervioe
Receipt for Certified Mail
No insurance Coverage Provided.
On not rise rnr lnTamnfinnm u.ir to. .. ....a
SENDER:
■Campleta name 1 andfar 2 for addrtierkd asrviotl.
--
l t� wish to rete to .
Str" d Number
r
PO BOX 487
WAR ASW ZiiCpP 28398
Postage S 3
a Priv¢ your name and address an She revsrM of this form so Chat we can raeum flit
CaMbed Fee 1.10
SPeaW l Fee
card to
• Attach mis loan to the forst al the marl km. or on
Restricted DQwV Fee
1. ❑ Addressee's Address
1°
to
Whm & Date Delvemd 1.10
�4
a
R4bsnbwhom.
cl
Date. & Adtres&Ws ftd m
0
Q
TOTAL Postage & Fees s e1•, Sv
Posm,a* or Date
delivered.
LF
3-25-97
IL
3. Arfide Addressed to:
SENDER:
■Campleta name 1 andfar 2 for addrtierkd asrviotl.
l t� wish to rete to .
r
•Mete rtems 3.44, and 4b.
blowing services (for an
ro
a Priv¢ your name and address an She revsrM of this form so Chat we can raeum flit
extra fee):
m
card to
• Attach mis loan to the forst al the marl km. or on
the bank d space does flat
1. ❑ Addressee's Address
to
•wri Retum Romp Raque■ho' on the ff0#0ce
bobw tha aWa h m*K
2. ❑ Rafttad Deltvsry
cl
■The Rehm Racso W show to whom the article ryas de werad and the doe
C
delivered.
C4ratitt posfnSBster for foe.
3. Arfide Addressed to:
4a. Amide Number
_
P 427 894 149
E
MR JIMMY VINSON
4b. Service Type
1 11
BROWNS OF CAROLINA INC
❑ Registered 91 Certified
PO BOX 487
❑ Express Md ❑ Inmoed
S
WARSAW NC 28398
❑ PAhn PWAV for Merdrendse ❑ OOD
7. Date of Delivery
s
0
a.
S. R By 'nt !Yams)
8. es s Ad est ( if
and b
t
6. Sig (A Agent)
0
a+
m
r
-
PS Form 11 D44ffbir 19%
Domestic Retum Receipt
t

v ROWN-10
1
OF CAROLINA
March 27, 1997
Kerr T. Stevens
Wachovia Building
Suite 714
Fayetteville, NC 28341-5043
Dear Mr. Stevens,
RECEIVED
APR 0 2 19471
F' c'TIEVILE
RcG. O;rjCF
This letter is in response to the Notice of Violation received for Farm 28 on March 12. Due to
the high level of the lagoon, irrigation of this land was necessary in less than ideal situations,
which led to the runoff observed on February 25. A large portion of the land included in the
waste management plan was required to be cleared and was delayed due to the extremely wet
weather last summer and fall.
Management of this farm has been difficult due to the slope and the heavy clay soils which was
made worse by the high lagoon. Every precaution was taken during the winter to prevent runoff
and these were discussed with DWQ inspectors. Since the DWQ visit of February 25, additional
measures have been taken to alleviate the level of the lagoon and the irrigation frequency on the
present fields. We utilized a soil injector to apply waste to the adjacent landowner's (Timmy
Blanks- owner, Harold Wright -operator) fields designated for corn production. Documentation
has been filed for the temporary use of these fields and we have the option for future use if
necessary. In addition to the injection procedure on adjacent land, irrigation of the present oat
crop has continued. The potential for runoff has significantly decreased due to the increased crop
stand and the drying of the soil in the Iasi few weeks. These efforts have been successful in
bringing the lagoon to a much more manageable level.
The fields in front of the farm previously seeded in oats are being prepared for coastal sprigging
which should take place in the next couple of weeks and will provide additional irrigation
opportunity. The soils are exceptional for crop production and will produce a sufficient stand to
minimize runoff on extreme slopes. We realize there are areas that will always need special
attention during irrigation applications and have discussed these with the employees responsible.
This farm has been a very high priority in our department throughout the winter and will continue
to be due to the slopes and the adjacent branch. We feel that the current waste management plan
when fully implemented will satisfy both the hydraulic and nutrient loading needed for this farm.
We are, however, continuing to evaluate this and will obtain the option to incorporate more land
into the plan if necessary.
BROWN'S OF CAROLINA. INC.
303 EAST COLLEGE STREET • P.O.9OX487 • WARSAW. NC,28398-0487 - OFFICE [phone] • FAX [phone]

In light of our continued efforts and the extenuating circumstances of last year, we ask that you
not recommend enforcement action. The DWQ Inspectors from the Fayetteville office have been
very helpful in providing technical assistance with this farm. We appreciate your support
and your consideration in this matter.
Sincerely,
G C.�
y -R. Vinson - - -
Mgr. Environmental Resources

State of North Carolina
Health Nigra Resources
FayettevlAe Regional Office
James B. Hunt, Jr., Govemor
Jonathan B. Howes, Secretary
Mr. Jimmy Vmson
Browns of Carolina
105 East College Street
P.O. Box 487
Warsaw, NC 28398-0487
Dear Mr. Vinson:
AIWA
ll,
1DEEHNFZ
DrMION OF WATER QUALITY
December 3, 1996
SUBJECT: NOTICE OF DEFICIENCY
Farm 28
Reg.# 09-155
Bladen County
On October 23, 1996, staff from the Fayetteville Regional Office of the Division of
Water Quality inspected the Browns of Carolina Company Farm # 28. The inspection
revealed that the lagoon serving this operation only had approximately 12 inches of freeboard
rather than the necessary 19 inches of freeboard and storage.
However, it has been noted by this office that the recent storm events have contributed
a great deal to the high freeboard levels in your lagoon and prevented you from land applying
the excess waste water at appropriate times. Tberefore, it is all the more important far you
to lower your lagoon level as soon as possible in order to obtain the nary storage volume
needed during the winter months. While h is essential to lower the lagoon level, it must be
done in such a manner that does not allow a discharge of waste to the waters of the State.
Failure to comply with these conditions can result in civil and/or criminal penalties or the
facility may be required to apply for an individual nondischarge permit-
Please
ermit
Please notify this office within thirty days of receipt of this notice at the address
below and list what actions have been taken to lower the lagoon level. Please be advised that
this letter does not prevent the Division of Water Quality from taking enforcement actions for
past or future violations.
wachovla BuEldhg. Site 714, FoyetteAe�t�'� FAX [phone]
North Carolina 28301 3 C An Equal Opportw tty AffimX9W Action Employer
Voice 91n..a Md l � --- - --- ----- -- - - -
i

Mr. Vinson
Page 2
1213/96
If you have any questions ming this waiter, please do not hesitate to contact
either myself or Michael Wicker, P.E., Water Quality Regional Supervisor at 910-48&1541.
Ssa=,oly,
Ed Buchan
Euvironmenw
cc: Michael Winker - WQ Regional Supervisor
Sam Warm - Bladen County MRCS
Chris walling - DSWC, FRO
Enforcement Files
Facility Compliance Group - Central pace
i
p

` Division of Eaviroamental Management
• Aima3 Feedlot Operations She Visitation Beard
• - . rc�J�3 9G
• Fa® NW=:—C cI r M ��_ , _ (�q r �►
pWUffv G.Yam No• - Xac,
On SiteReprzscntative• sz a o 1. n o.�baexruwA G
.....�
Mailing Address•
Physical
L8 3 Ci
R�catiatn: r� ..,.r► a t 1 . -r.�.r G 1 Gtf-u
r
• . Latitude: _ J 1 Longitude: 1 I
Operation Descj�ptiow (based on derma )
'rype of Swiss No. ofAnimk 'fa saw Type =amUry Ab. oJMimk of No. ofMk
Ctmsrry 0 Non-lsyw Q &d
13 Feder
!terType ofL wuoet .. 1Vwnber of Anct=&.
Number of Lagoons: _I_ _(include in the Drawing and Observations the hwbosrd of each logo=)
Iagoon
_
Is lagoon(s) freeboard Jess than 1 foot + 25 year 24 hour storm storage?:
Yeses,
No 0
.Is seepage observed from the.byp n?:
Yes 0
No,�M
Is erosion observed?:
Yes 0
No 10
Is any discharge obsm-nd?
Yes 0
NqZ
Q Slan-NOde 0 Not Afm wak
Coyer Crop
Does the facffity need mom acreage for spraying?:
Yes O
Nth
Does tine cover crop Deed unprovemeW:
Yes�W
No 0
(An du crops which need improver") ?
,
Gap type:
Setback CHierk
Is it dwelling located within 200 feat of waste application?
Yes O
N9Z .
Is a well located within 100 felt of wasfle application?
Yea C1.
Nod -
Is animal waste stockpiled within 100 feet of USGS Blue Line Stream?
Yes 0
NOP
- 'Is aminal waste land applied or spray irrigated w#then 25 feet of Blue Line Stream?
Yes 0
Nal
Ani — Janaary I7.Yl9d
- _....•
; . t. • •,

s

a
HEMORANDU
DATE: April 25, 1997
TO: Steve Tedder, Section Chief
Water Quality Section
FROM: � Ker. Stevens, Regional Supervisor
Fayetteville Regional Office
SUBJECT: Recommendation for Enforcement
Unpermitted Discharge'of Swine Waste
BOC # 28 - Browns of Carolina, Inc.
Hwy 211, Bladenboro
Bladen County
Find attached a fast track enforcement package pertaining to the
discharge of animal waste from the subject swine facility. The
attached inspection form will detail the basis for the action as
well as serving as a list of assessment factors.
Also attached is a letter for the Director's signature recommending
the revocation of the "Deemed Permitted" status of the facility if
the facility fails to come into compliance.
If additional information or clarification is required, please
advise.

State of North Carolina
Department of Environment, 74��Vjl
Health and Natural Resources
Fayetteville Regional Office
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
June 13, 1997
Certified Mail
Return Reciept Requested
Mr. Jimmy Vinson
P.O. Box 487
Warsaw, NC 28398
SUBJECT: Operation Review Corrective Action Recommendation
Brown's of Carolina Farm #28 Facility No. 09-155
Bladen County
Dear Mr. Vinson,
On June 11, 1997, an Operation Review was conducted of BOC Farm #28. This Review, undertaken in
accordance with G.S. 143-215.1 OD, is one of two visits scheduled for all registered livestock operations during the 1997
calendar year. The Division of Water Quality will conduct a second site inspection.
During the Review, it was determined that waste was not being discharged to the waters of the State, and the
animal waste collection, treatment, storage and disposal systems were operated under the responsible charge of a
certified operator. However, the following management deficiencies were discovered and noted for corrective action:
1. Lagoon has only 6" of freeboard with only 2 of 9 fields that have a crop which can be
irrigated.
2. Talk with Kathy Dugan at Bladen Extension about weed control. Wild mustard is very
prevalent in the coastal fields.
3. Two (2) fields have coastal established. The other seven (7) have oats planted to be cut and
sprigged next week. Only 4 months of coastal growing season left.
These management deficiencies need to be addressed and corrected. You are encouraged to contact your certified
technical specialist if additional assistance is needed. The following reviews and inspections will re-examined these
deficiencies to determine if corrective actions were implemented.
Wachovia Building, Suite 714, FayettevilleNt'w
� FAX [phone]
North Carolina 28301-5043 AnEqual Opportunity Affirmative Action Employer
Voice 910-486-1541 50M recycled/ 10% post -consumer paper

Due to the fact that the oats have not been harvested and July is approaching, I would not suggest following the
cuhrent Waste Utilization Plan. Your Nitrogen loading rates for coastal bermuda are all between 300-325 lbs/ac. This rate
will be too heavy with only 4 months of application time left (July -October). After talking with faculty at North Carolina
State University (Dr. Hodges, Soil Science and Dr. Bums, Crop Science), Bladen County NRCS ( Sam Warren ), and
the Division of Water Quality, you have two options:
1. Sprig the coastal now and apply 50% of the Nitrogen allowed because only 4 6f the usual
8 months are left in the growing season ( For Exum soil, this would be 183 lbs N/ac).
-or-
2. Revise your Waste Plan for another crop that would take up the most nitrogen. The only
crop you could plant at this stage to take up the' most nitrogen would probably be soybeans
followed by small grain overseed - to be cut in March. ( For Exum soil, this would be
200 lbs N/ac plus 50 lbs N/ac on small grain. Adjusting this for soybean residual, you would
have a total of 230 lbs N/ac you could apply). Cutting the small grain in March would allow
you to sprig the coastal then and use the full nitrogen loading rates.
I recommend that you choose option 2 for several reasons. First, this farm received an NOV in March 1997 for
discharging to water of the state and has been recommended for enforcement action. You do not need to risk having
runoff again or a high lagoon. Second, the lagoon has only 6" of freeboard and you will need to pump to keep the lagoon
from over -topping. The soybeans/small grain will allow you the higher application rate. Finally, the permeability of Exum
soil is slow. You will not be able to apply the full amount of nitrogen to the coastal in 4 months that should have been
applied in 8 months without having ponding and runoff. However, in both cases it may be necessary to pump the lagoon
down and use it for precharging the new lagoon located on BOC Farm #93. Please respond in writing with your decision
regarding this matter by July 11, 1997.
In order for your facility to remain in compliance with environmental regulations, animal waste cannot be
discharged into the waters of the State, and the animal waste collection, treatment, storage and disposal systemsunLst be
properly maintained and operated under the responsible charge of a certified operator.
Please remember that if you do not have a certified animal waste management plan, you are required to do so by
the end of this year. The plan must be certified by either a designated technical specialist or a professional engineer. For
additional assistance with the plan, please contact your local Soil and Water Conservation District Office or local
Cooperative Extension Service Office.
The Division of Soil and Water Conservation appreciates your cooperation with this Operation Review. Please do
not hesitate to call me at 910-488-1541 ext. 224 if you have any questions, concerns or need additional information.
Sincerely,
Audrey D. O endine
Environmental Engineer I
cc: Sam Warren - Bladen Co. NRCS
Ed Buchan - FRO DWQ Environmental Engineer
DSWC Regional Files

[� 1)SN1 f A11i111:11 Vve(iIf) f I Iv1'afintt Rc1 iv11.
` ❑ f)t� (1 :Iniltf:rl f-�'ctllnf {)1)r1.1firf11 Cif(' f11s1)rrfirtrt
� [lnutine U I:nm F;rhtt Q Inllw++-u of I)tl�( ins cellon U 1 nlfn+s-u n1 i)tilt(.' fccir+i U tlthrr
Fac'11#rt trrmhr•+
1 itnr of htspc•rt;vm . CT) 2.1 lit . (hlt:tnnT)
i frfal I i1m lin h nclinrr .rf 116111,
_
[JfirgicTlrrri ❑.1},rfif,}fnt i'rrrail rrr 1 '� (n1 f lrr 1; C1+rnf nn 14ti,tt
r rrrn Cfahrc: C r rr rilirrl �Q f'cr Irt;ltr,l of 11112 teoir,rl I111clurh•s rt a+ 0 stiff rl nrestirt
�.1 fin} 111212.1 rfinnal 1ral�' f .ra rltrrt:lft'r}•
.... ........... .._. .........................
I iffnt \ rTnr: f'otrrll+ 7 ............ (-/%........................ .......................
7 ,
(hrnrr \anrr - 15-e °�[#I.S.._I._...3C�/Cr��n. : ............ .. I•hnor 1n: ........ �1:...:..: ��9�'...:....�F � �...........................
......CJf/7/JSC� -. ... iiflr ..................' t�hnnr Vn: /C1 ............................. �FC)%�
l'[li.!![' ....................��
7
Onsite"rtVTIHII„-: ... _... pp
/C/V-9..-7` d�r?5................. h,trer 1rnr:..............��.... ­ .........................................................
crf fiiiecl l)lrrr:,fnr : ...............1...<t.P.............
...........
.......
....
..._....._.._ t,l►rr rtrrr (rt tificat#rrrt Nunr#rrr:. ...._.._.............
Local#un orl-:rrm: ,J
.............................................. ........................... .................. ... I.... .......... ----.......... ........ ............................ ...... .......... ...... ................... ..............
... t?
.._................................................................j......................................_._..............................................._........----......................----..............................----:....----••-•------..... {:
1 - L-A A 1,.
Tit pe of (aper nfinn
1)rti�n ('mrrill N1•cl1_+n t"mrcnf I)csi$!n faitf -rut
twine Ca achy PaLtul311nif Foultr} — (:a}tacity Pnritflafion Cattle — Caltaclty P_o_liulaflon
rFartow
eeder _Laver Q Uairv'
Finish_ --_- i Non -Laver -�-- — - __ Nott-Dairv�
ll tan C_ Feedcr -for=d llrtit!tt (":tpneity I=inich
❑Othrr - -- '
NdM' frrr d Lagnnnt 1 ifnirfinQ Pnnrfc � , �jSuirsurface 1)r2int I'tONCti T U Lap,untt At ea Sl,rav fiel(_1A rea
General
1. Ate ffrrrr am I,.III •te that „ctrl maim• n,rt r +rnr+tn�rrnrnf'
2. Is :Tett' diccitatc^ ,+h•:^t1 c -d f, nn, arry rats ,+1 11tr• nrrl'11inn:'
11i :, h,I!'r ,a i�rinair,l ar i t :+rr'+•n L1 C1+rat f i, 1+1 1.1 1 12(11+ r
if •li :rh:,jL•,- i• r+hgrl + •',i. o+ r: ilrr• r•+nit e% ;I Iu•c• In:m nr:trlt•
1, if 4;-,-111ree is nl+c,•,t".l-,1ir1 it Iv:tch Sttlf.a,'+• W. ?I eI (11 xcc. t,niil} itll'fr1
11 I i -d 1.11 uc is n},<cI'L •!. x.11:11 is rhr uCtittl:Iff•II Ih,, l in 12:11 1tlitl
,i I'r„'•: ,iieritnrY•• h�1•:. 'r lae•„r+n :+ ar,11' ill .r•; rrn+ill illl'r rT
is f1lne c,i+1^nr:• .•( r:rct rli<rttati*r ft„t+, -I+n r•-Irt of rh•• nrr•,:rti,.n'
•1. ll � tc Ihr,r :rr,r ,i i,nr•'+•'t': rr. ,1,.. ,.r „1 rl�.• Crag• .•,I, r +I„,h,.n+ :1 rli ,'h +, r+••
S. i or•< raft ,•1 ,i,.. ., .r r., nr:n,:,,+. m—If , I- M 11.12(,• r 111:11+ I „•..,.,,.- I,••Llinf• 1•+•10-:1 r,•.Ini,r
rtt:ti„I,•r+:ttr r i,nr•r,+, rn,• n1
41111"l-,
[.) Yes No
No
I.1 }"r� P. No
f 1 l ct y r1„
r',rruitrrrrr! „n ha, A

.. �a ... i. •1�II:. +. ._.... ..
............
6_ is facility nm ill ro mpliA lice I.Vith :111 -.11,14ical,ir CCll,:IA Atretic iii <-it•`C: it oliv tlm1•` of Jr-imi"
7. Did the facilitt• flil Io hive n crrti[icrl r`t`•'tarr+T it1 t^'-rr,Tl�lt,lr rll:fil••`'
S. Are there iaimons or storage prIntls on site offish nerd In he ptopctly closed?
Sittiefiftei It,avvnnnt and/or iloldl_rry-1'nnrl5)
9. is slornge capacity (rieehnard phts ornin stntlQ^) less 11tan arlrtln'lit- 1
rreelmard (fl): Sirtictilre i Str11t•fitirr 2 SIr11r1111C ?
- .... ..,....... ................... ___..... ............................
Sttli mtrc 4
10. is seepage nhsrr%Cr} rrom any of the :1iitrtivtrs? ❑ Yes O No
11. is erosion. nr ant• olher threats In fhc intretitc of any of the ctrnrtmrc olisptccd:' U Yes No
i2. Dn any of rhe atnirtmes need Irninlcnlnrr-irnpmventrnl? rJ N -pe O'11n
(1t any of ritirglinttc 9-12 a as ancn ri eff %es, and flip titimilon pnars an
Immedlate pnh1ic health or r"Otntimental flit -pat, nnflfy D111))
13. Do any Of the stntctttres lack adegitalr minirtinin lir mazinllnn ligiiid kwel imikers' El Yes J� Nn
Waste Appllcptlnn
14. 1s there phyrical c-, idence nr n{•rr nrl,lic:Ttion? U Yes Kt,in
(1f in exec -ca of [l'm. or ninoff rritr`r ifm n titers of flip SmIr, notify f IWO)
15. crop tyre _....%' ���� � :.o. s:?.ttc�c�.<....................... ....I................. ................... ..................... ................................. ..........
_ _.......
16. Do the rccri'Littg rrops differ with thncr ticciptimed in the Anittral Wncte klanaeement Plan (AWN[1'1? ❑ Yes No
17. Does the f:•tcility b -o e a lack of ad• giinlr arrcar±r flit 1anc1 arr[iratirill? ❑ Yes No
18. Dnec 111c rrc-il itle rrnr nerd imrim-i lrtlt." MYr,.;❑ No
19. 1s there a lack of .-linable tt' 1Ctr :ttirlir16-1 er{nipincnt"? ❑ Yes f_J No
20. ones racility regiiitr a rnllnly-tir %kil hr -bene nernr.y? ❑ Yes No
21. Did Re{•iewerrintpertnr r it to diecti" rrviry/inspeclinn with nn -ails rcrresentatire? ❑ Yes � Nn
tnr CmI fid-Facllit!eq-9"L
22. Does the facility fail to have a cnry fif the Anirml Nagle ill nitsrinent f Ian readily ayailiblc? ❑ }'es No
23. ;'etc any acldi!inn ti rrahlems nnlett l" hich entice nnneninphince lir the Cerlified A%VktP? yes J�Nn
24. Does recnrel �"pine nerd imprttl'rnif,Ilt? ❑ Yes No
Comments (trrcr to ri,Teztinn Y): Psplain ntrt, ti'FC ntiaicris anri'm ani,• mcnmtn^tiflationa lir any litho Cn1n111PIVIZ.
Use dran'inga of fariiity to better rzpllin ^.ititati„na (it” arltlifinti'1I rarra as nerrcaar> j:
fit
9•tc)�t �_. �..+f 7 ,',circ%.��rtic( .�
ja.�ft�
i/
n r
f �: �a ''n� f l'/*n P
SCtt1 �F� -i'�•_ ..�..�, �c�r' /[tCr.,,r.�r,vt �f,�N 1:r; r�,il.c• ��r'� `�' �� •'' ,1s.•. �c� _
l
ltei•leiver/Imperrrir N:iTT1C _ _iltif/['r}- i1L.4� _ -- -- -- — - -- --- - ---- ------
1ZrsdPS{'rr11n{rrrinT �InTlaflilr; + _�, lfarr -- /.-�%_ ��
Ll Yea
[ �tln
t-
YN
C1 pili
Shrtrinir � Stntrhtrt (+
10. is seepage nhsrr%Cr} rrom any of the :1iitrtivtrs? ❑ Yes O No
11. is erosion. nr ant• olher threats In fhc intretitc of any of the ctrnrtmrc olisptccd:' U Yes No
i2. Dn any of rhe atnirtmes need Irninlcnlnrr-irnpmventrnl? rJ N -pe O'11n
(1t any of ritirglinttc 9-12 a as ancn ri eff %es, and flip titimilon pnars an
Immedlate pnh1ic health or r"Otntimental flit -pat, nnflfy D111))
13. Do any Of the stntctttres lack adegitalr minirtinin lir mazinllnn ligiiid kwel imikers' El Yes J� Nn
Waste Appllcptlnn
14. 1s there phyrical c-, idence nr n{•rr nrl,lic:Ttion? U Yes Kt,in
(1f in exec -ca of [l'm. or ninoff rritr`r ifm n titers of flip SmIr, notify f IWO)
15. crop tyre _....%' ���� � :.o. s:?.ttc�c�.<....................... ....I................. ................... ..................... ................................. ..........
_ _.......
16. Do the rccri'Littg rrops differ with thncr ticciptimed in the Anittral Wncte klanaeement Plan (AWN[1'1? ❑ Yes No
17. Does the f:•tcility b -o e a lack of ad• giinlr arrcar±r flit 1anc1 arr[iratirill? ❑ Yes No
18. Dnec 111c rrc-il itle rrnr nerd imrim-i lrtlt." MYr,.;❑ No
19. 1s there a lack of .-linable tt' 1Ctr :ttirlir16-1 er{nipincnt"? ❑ Yes f_J No
20. ones racility regiiitr a rnllnly-tir %kil hr -bene nernr.y? ❑ Yes No
21. Did Re{•iewerrintpertnr r it to diecti" rrviry/inspeclinn with nn -ails rcrresentatire? ❑ Yes � Nn
tnr CmI fid-Facllit!eq-9"L
22. Does the facility fail to have a cnry fif the Anirml Nagle ill nitsrinent f Ian readily ayailiblc? ❑ }'es No
23. ;'etc any acldi!inn ti rrahlems nnlett l" hich entice nnneninphince lir the Cerlified A%VktP? yes J�Nn
24. Does recnrel �"pine nerd imprttl'rnif,Ilt? ❑ Yes No
Comments (trrcr to ri,Teztinn Y): Psplain ntrt, ti'FC ntiaicris anri'm ani,• mcnmtn^tiflationa lir any litho Cn1n111PIVIZ.
Use dran'inga of fariiity to better rzpllin ^.ititati„na (it” arltlifinti'1I rarra as nerrcaar> j:
fit
9•tc)�t �_. �..+f 7 ,',circ%.��rtic( .�
ja.�ft�
i/
n r
f �: �a ''n� f l'/*n P
SCtt1 �F� -i'�•_ ..�..�, �c�r' /[tCr.,,r.�r,vt �f,�N 1:r; r�,il.c• ��r'� `�' �� •'' ,1s.•. �c� _
l
ltei•leiver/Imperrrir N:iTT1C _ _iltif/['r}- i1L.4� _ -- -- -- — - -- --- - ---- ------
1ZrsdPS{'rr11n{rrrinT �InTlaflilr; + _�, lfarr -- /.-�%_ ��

jii7 1 i ,99 MON 1 i:12 FM BROWN c
January 18, 1999
Jeffery Brown
NCDEHNR - Fayetteville Region
225 Green Street Suite 714
Fayetteville, NC 28301
Dear Mr. Brown:
FAX NO. 9102961676 F.
VT Glen Davis
Browns of Carolina, Inc.
P.O. Box 487
Warsaw, NC 28398
At approximately 4:00 p.m. Tuesday afternoon January 12, 1999 while charging an irrigation line
on BOC Farm 28 at Clarkton, the air relief line at the 6 inch underground gate value adjoining
CSX railroad split, discharging swine waste water into the ditch adjoining the railroad. The pump
was immediately shut down and cleanup started. We cannot be sure as to the amount discharged,
but believe it to be small since everything was stopped immediately. However the ditch was
standing with about one foot of fresh water in it from previous rains, making the cleanup much
larger than it would have been.
On Wednesday January 13, 1999, I called the regional office at 10:00 a.m., all ag. personnel were
out and 1 requested that one return a call to me. I waited by the phone for 3 hrs. and upon
returning to the office that afternoon, had a message on my voice mail from Ken Averette_ It was
then 6:30, he had tried to reach me that morning on my mobile but was unsuccessful.
On Thursday morning January 14, 1999, I returned a call to Ken, and set up to meet him at 11:30
on the site. He arrived, looked at the site, what had malfunctioned, and what we were doing to
clean up. He indicated he was satisfied with what was happening and would put a note on your
desk to that affect.
Jeffery, I'm sure you are familiar with the site. Entering the farm the ditch on the south side of
CSX and the east side of the crossing was contaminated. A pump was set up at the crossing and
hooked into the irrigation line to pump the water back to the lagoon. After pumping down the
bulk of the water a smaller pump was used to pump out the pot holes. Ager pumping up all we
could the area was flushed with approximately 5000 gallons of fresh water and this was also
reclaimed and sent to the lagoon.
The culvert at the crossing had been blocked and no water ever moved to the left or west side of
the road.
BROWN'S OF CAROLINA, INC.
785 HW►Y 24 EAST • a.0. BOX 4e7 . WARSAW. N.C. 25395 • PHONE (410) 2WI800

J"xN`18:99 MOIL 12� 13 PM BROWN a _
Fg NO, 9102961675 P. 3
Upon finishing on Thursday afternoon, we have recovered all the waste water and upon
inspection Friday morning the culvert was opened.
If you have any further questions, please call me at [phone].
Thank you,
f)hl.,
Glenn Davis
Brown's of Carolina, Inc.

Jeffirey,
I went to the Brown's 28 farm at around U. Thursday. It was exactly like Gen Davis said. The
connection to an air relief on an irrigation main broke, spraying waste into the railroad ditch and
onto the ground around the pipe. This break was about a 100 yds, south of the dirt road going
into the farm. They had blocked the culvert under the road and contained this material. Most of it
was pumped back to the lagoon when a transfer pump broke. They weren't finished when I left,
but they contended that it would all be up today. There was probably 1000 gallons or less left in
the ditch. Told them that some of your guys would probably see them tomorrow. Nothing made it
to real surface waters. I looked downstream at the road x-ing and it was clean.
r�

1
BROWN"s
OF CAROLINA
January 18, 1999
Jeffery Brown
NCDEHNR - Fayetteville Region
225 Green Street Suite 714
Fayetteville, NC 28301
Dear Mr. Brown:
Glen Davis
Brown's of Carolina, Inc.
P.O. Box 487
Warsaw, NC 28398
2 0 1999
t,.�•.L L C
REG. C:-F:CE
At approximately 4:00 p.m. Tuesday afternoon January 12, 1999 while charging an irrigation line
on BOC Farm 28 at Clarkton, the air relief line at the 6 inch underground gate value adjoining
CSX railroad split, discharging swine waste water into the ditch adjoining the railroad. The pump
was immediately shut down and cleanup started. We cannot be sure as to the amount discharged,
but believe it to be small since everything was stopped immediately. However the ditch was
standing with about one foot of fresh water in it from previous rains, making the cleanup much
larger than it would have been.
On Wednesday January 13, 1999, I called the regional office at 10.00 a.m., all ag. personnel were
out and I requested that one return a call to me. I waited by the phone for 3 hrs, and upon
returning to the office that afternoon, had a message on my voice mail from Ken Averette. It was
then 6:30, he had tried to reach me that morning on my mobile but was unsuccessful.
On Thursday morning January 14, 1999, I returned a call to Ken, and set up to meet him at 11:30
on the site. He arrived, looked at the site, what had malfunctioned, and what we were doing to
clean up. He indicated he was satisfied with what was happening and would put a note on your
desk to that affect.
Jeffery, I'm sure you are familiar with the site. Entering the farm the ditch on the south side of
CSX and the east side of the crossing was contaminated. A pump was set up at the crossing and
hooked into the irrigation line to pump the water back to the lagoon. After pumping down the
bulk of the water a smaller pump was used to pump out the pot holes. After pumping up all we
could the area was flushed with approximately 5000 gallons of fresh water and this was also
reclaimed and sent to the lagoon.
The culvert at the crossing had been blocked and no water ever moved to the left or west side of
the road.
BROWN'S OF CAROLINA, INC.
785 HWY 24 EAST - P.O. BOX 487 - WARSAW, N.C. 28398 - PHONE [phone]

r
Upon finishing on Thursday afternoon, we have recovered all the waste water and upon
inspection Friday morning the culvert was opened.
If you have any further questions, please call me at [phone].
Thank you, .
�-
Glenn Davis
Brown's of Carolina, Inc.

FEB -20-99 SAT 12:23 PM BROWN S FAX NO. 9102961675 P. 3
P.O. Bax 487, Hwy 2460 East, Warsaw, N.C. 28398
1 BVI -8 6 Fax: 2966] B6
FaX
To.. Je*ereN {5rd-jr,
Fr+orm
I
Fac
Phoe.e ae.t« 1.o l�
Re: cc:
❑ Urgent �Wor Review ❑ Please C4mme st © Please Reply Cl Please Recycle
® or y �! I'S / j %I¢�17 1U /L/ l7 r • •' o SG G r e • +, lu / e
low -
,q -n d Sen I o U R -so s
fiP 44,5A�, /
r

FRB -20-99 SAT 12:22 FM BROWN S FAX NO. 9162961676
P, 1
Iva" aoce t1'l�o _� s�/V // *v been�eip6-
CA
1.r/, LWe S�ss�alo ewe/ y e cs
.._ I����!� � lit G! Q�i►/1 �}?'1 �fJ /�l�t.a-�'i.✓L✓ ! f -
e/7 fv
J-0 It.
9 "Old
�r t s vGc cis _� �.✓7_ g.11
a�
sil
/a a A4) -,_g 1-t Ga d B __w

PED -20-99 SAT 12:23 PM BROWN S
FAX NO. 9102961675 P. 2
l _
4ow.aAo
z29 4,re- 4f Pe r. ►4'h (�y r
._.___--� __ �++► psQ.�Q e s �.� d,.��- 1 ow besi rrta na.
jr-'�e
919.: 42-fz— ko - ._...___. �.._.
GG-

MAF; 5-99 FRI 3:01 PM BROWN S FAX NO. 9102961675 P. 3
. P.O. Box 487, Hwy 240M East, Warsaw, N, C. 2B,39B
Z 2871$928 Fa;c 2966168
r ,
FaX
Toi a -U i AIJ LS From _S.rowwfz
Face q !D - _LMjV - D? D % 3
Phoawa Dntr.
Rrs CC:
11 Urgent MI -0; Revww ❑ Please Co nnmot ❑ Plo=e Reply © Please Rocyeie
/H/4/ i NL1 A
RECEIVED
"'AR 0 5 1999
FAYETTEVILLE
REG. OFFICE

MAR- 5-99 FRI 3:00 PM BROWN S FAX NO. 9102961675 P. 1
i'
VV
March 5, 1999 -AA —It*
Mr.Paul E. Rawls
NCDENR - DWQ
225 Green Street
Suite 714
Fayetteville, NC 28301
Dear Mr. Rawls:
This letter is in response to the "Notice of Recommendation for Enforcement" received by Mr.
Greg Brown dated February 23, 1999.
Brown's of Carolina, as stated in earlier conversations, sincerely regrets the discharge that took
place on BOC 28 on February 12, 1999. The discharge was a result of the operator not using his
best judgement as to the application rate during this period. The employee's that were
responsible have been dealt with in this case for their lack of judgement. Brown's of Carolina
has always tried to instill in all of our employee's that we cannot and will not tolerate any
discharges. This discharge was not intentional but was due to a lack of caution.
In response to the action items that you requested., we have developed strategies to address each
of them.
As the weather permits we are currently continuing our efforts to lower the lagoon level to the
desired elevation. Additional people are being used to be there and monitor all activities. Glenn
Davis, our Farming Manager is personally devoting the necessary time to supervise these efforts.
We have relocated all of the possible needed equipment to help in the effort.
In examining why the lagoon level was high, I can only give two reasons. First, January did
present us with rainfall and our operators thought they were doing the right thing in delaying as
long as possible any spraying. What hurt our efforts the most was that during this period the
production facility was using an excess amount of fresh water. The water use is being closely
monitored to help alleviate this part of the problem.
All deficiencies will be corrected on the erosion issues as the weather and seeding dates allow.
I think our efforts to clean the discharge shows our commitment in solving these and any other
potential problems that may arise. I have offered to have DWQ review the clean up and meet
with your staff at anytime.
BROWN'S OF CAROLINA. INC.
785 HVJY 24 FAST • P O. SOX 487 . WARSAW. N.C. 28398 • PHONE [phone]DO

.. .MAR- 5-99 FRI 3:01 PM BROWN S FAX N0. 9102961675 P. 2
To go even further, our willingness to work with DWQ on these issues and others is illustrated
by our agreement with the division to do ground water monitoring on this farm. I would
recommend that you review this document to validate our willingness. This document was
signed by the division and Greg Brown.
I would hope that our cooperation would help convince you that an enforcement action is not
necessary. Brown's of Carolina accepts the responsibility for what happened and will take the
necessary actions to make sure this does not occur again.
Thank you Mr. Rawls for this chance to make our concerns and views known and hope that it
makes a difference in your decision.
Sincerely,
J' y Vi
Development Manager
Brown's of Carolina, Inc.
]V/ep
cc:Greg Brown
Glenn Davis

IR
February 24, 1999 ;l I
Jefferey Brown ` ��`�t. t� • , RECEIVED
D WQ-DENR
Wachovia Building, Suite 714` X999
Fayetteville, NC 28301 FAYP TEVILLE
AEG. ^��1rE
-••v
Dear Jefferey
This letter is a follow-up to the discharge and visit to BOC 28 in Bladen County. The discharge
occurred because the operator in charge was using too high of an application rate. While he did
not exceed the rate for this soil type, it was too high for the conditions. This should have been a
management decision made by him at the time or he should have conferred with me if he was not
sure. Also, he should have been monitoring the application more closely. These are things that
we have stressed to our employees. We regret the incident and will do whatever it takes to make
sure that it does not happen again.
After your visit on Friday afternoon, we took every step possible to reclaim the effluent and clean
up as much as possible. I feel we were successful in getting all of the effluent out of the ditches
but because of the light rain on Friday some may have gotten past the point of recovery.
We have made some decisions that will help eliminate this from happening again in the future.
Brown's of Carolina is committed to operating our farms in the best way possible.
I am available at any time to review this farm and our approach to the operation of this farm
whenever it is convenient to you.
Again we regret that this happened and that our employees did not follow the best management
practices for applying wastewater.
If I can be of any further assistance or you need any additional information I can be reached at the
office: 910-296-1800 Mobile: [phone] or my home: 910-658-4212.
Thank you for your help and as always your concerns.
';evelopment
cerely,
yVianager
Brown's of Carolina
JVlep
CC: Greg Brown
BROWN'S OF CAROLINA, INC.
785 HWY 24 EAST • P.O. BOX 487 • WARSAW, N.C. 28398 • PHONE [phone]

March 5, 1999
MrTaul E. Rawls
NCDENR - DWQ
225 Green Street
Suite 714
Fayetteville, NC 28301
Dear Mr. Rawls:
R46.rXI V ,:
A,q 0 8 1999
FAYE TEV1
REG. OTFI
This letter is in response to the "Notice of Recommendation for Enforcement" received by Mr.
Greg Brown dated February 23, 1999.
Brown's of Carolina, as stated in earlier conversations, sincerely regrets the discharge that took
place on BOC 28 on February 12, 1999. The discharge was a result of the operator not using his
best judgement as to the application rate during this period. The employee's that were
responsible have been dealt with in this case for their lack of judgement. Brown's of Carolina
has always tried to instill in all of our employee's that we cannot and will not tolerate any
discharges- This discharge was not intentional but was due to a lack of caution.
In response to the action items that you requested, we have developed strategies to address each
of them.
As the weather permits we are currently continuing our efforts to lower the lagoon level to the
desired elevation. Additional people are being used to be there and monitor all activities. Glenn
Davis, our Farming Manager is personally devoting the necessary time to supervise these efforts.
We have relocated all of the possible needed equipment to help in the effort.
In examining why the lagoon level was high, I can only give two reasons. First, January did
present us with rainfall and our operators thought they were doing the right thing in delaying as
long as possible any spraying. What hurt our efforts the most was that during this period the
production facility was using an excess amount of fresh water. The water use is being closely
monitored to help alleviate this part of the problem.
All deficiencies will be corrected on the erosion issues as the weather and seeding dates allow.
I think our efforts to clean the discharge shows our commitment in solving these and any other
potential problems that may arise. I have offered to have DWQ review the clean up and meet
with your staff at anytime.
BROWN'S OF CAROLINA, INC.
785 HWY 24 EAST • P.D. BOX 487 • WARSAW, N.C. 28398 • PHONE [phone]

To go even further, our willingness to work with DWQ on these issues and others is illustrated
by our agreement with the division to do ground water monitoring on this farm. I would
recommend that you review this document to validate our willingness. This document was
signed by the division and Greg Brown.
I would hope that our cooperation would help convince you that an enforcement action is not
necessary. Brown's of Carolina accepts the responsibility for what happened and will take the
necessary actions to make sure this does not occur again.
Thank you Mr. Rawls for this chance to make our concerns and views known and hope that it
makes a difference in your decision.
Sincerely,
JLyv-
Development
Manager
Brown's of Carolina, Inc.
JV/ep
cc:Greg Brown
Glenn Davis

Facility Number: p — 155 Date of Inspection
5. Are there any immediate threats to the integrity of any of the structures observed? (ie/ trees, severe erosion,
seepage, etc.)
6. Are there structures on-site which are not properly addressed and/or managed through a waste management or
closure plan?
(If any of questions 4-6 was answered yes, and the situation poses an
immediate public health or environmental threat, notify DWQ)
7. Do any of the structures need maintenance/improvement?
8. Does any pact of the waste management system other than waste structures require maintenance/improvement?
9. Do any stuctures lack adequate, gauged markers with required top of dike, maximum and minimum
liquid level elevation markings?
Waste Application
10. Are there any buffers that need maintenance/improvement?
11. Is there evidence of over application?Ponding ❑ Nitrogen
12. Crop type ...........................................
a-ia-
❑ Yes ❑ No
13. Do the receiving crops differ with those designated in the Certified Animal Waste Management Plan (CAWMP)?
14. Does the facility lack wettable acreage for land application? (footprint)
15. Does the receiving crop need improvement?
16. Is there a lack of adequate waste application equipment?
Required Records & Documents
17. Fail to have Certificate of Coverage & General Permit readily available?
18. Does the facility fail to have all components of the Certified Animal Waste Management Plan readily available?
(ie/ WUP, checklists, design, maps, etc.)
19. Does record keeping need improvement? (ie/ irrigation, freeboard, waste analysis & soil sample reports)
20. Is facility not in compliance with any applicable setback criteria in effect at the time of design?
21. Did the facility fail to have a certified operator in responsible charge?
22. Fail to notify regional DWQ of emergency situations as required by General Permit?
(ie/ discharge, freeboard problems, over application)
23. Did Reviewer/Inspector fail to discuss review/inspection with on-site representative?
24. Does facility require a follow-up visit by same agency?
❑ Yes ❑ No
❑ Yes ❑ No
❑ Yes ❑ No
❑ Yes ❑ No
[]Yes ❑No
XYes [-]No
[:]Yes ❑ No
❑ Yes ❑ No
❑ Yes ❑ No
❑ Yes ❑ No
❑ Yes ❑ No
❑ Yes ❑ No
❑ Yes ❑ No
❑ Yes ❑ No
❑ Yes ❑ No
❑ Yes ❑ No
❑ Yes ❑ No
❑ Yes ❑ No
0_ N�o.vi6]a'tiorts:or def7ciencies Were no eid*dttring Ais:visii.. Ynu.i t!fret:eive nQ ftiriher.:.'
c-orrespirideiiee;about;this visit.;•.•;•;•;•;•;•;•:•;•.-;.;.;•,•,•,•;•,•.•;•;•;-;-;•.-;*;•:-;.;.;-:.;.;. .
Comments{refer to question #): Explain any YES answers and/or any reconiiriiendations or any other comments.^ -_
Use drawings of facility. to better explain situations. (use additional pages as necessary):
1
All.
4L e 24
t
T
Reviewer/Inspector Name
Reviewer/Inspector Signature: Date:
/ if _J
1/6/99

Facit4y Number: Of — .fir Date of Inspection
Addihouat:C or D
ng
omments and/ ra _
U.�l per[ rLav( #J►� .. 2 a �� y �GB�cipja 4� J r
a
L4a-,
�a
-� - -�u, Alm
Ale
LAj
r
UNIf
7125197

Dwrsron of Siirl and -Water Conservation =" Operation Rey�ew t c
_ ;
Dwrsion of-Soil'and.WaterC-onse-rvation - Compliance 1pspection L;_ ' "'
f:`Vater ualiCom hance'Ins ecti- n -�
h p P -
. ' Othe6 Agency :Operation Review - - -
14PRoutine O Complaint O Follow-up of DWQ inspection O Follow-up of DSWC review O Other
Facility Number Date of Inspection �—
Time of Inspection 24 hr. (hh:mm)
Kpermitted 0 Certified 0 Conditionally Certified © Registered JE3 Not OperationA OperationalDate Last Operated:
Farm Name:..........rufYl.S......L.�...G!!,1!Y!?.. Q'` County: r ............ ...............
Owner Name: ................. �— Di;t7,,2.� .... Phone No: ..` ..a y am......
Facility Contact: .............t:�....Il.t.�L rY'�L..... title:............... Phone No:...................................................
flailing Address:.............%.................L................................iflr�.lye.^....�.............................. ...��
........1% ....... Q .!'"�
Onsite Representative :..................... -.r..ck ..... .................... Integrator:.......1.1. 5.... ..... 'p`.`. G� .
Certified Operator: ..................... 'cec5........................... Operator Certification Number: ..........................................
Location of farm:
r.................................................................................................................................................................... y -
Latitude 0'OG O:G Longitude
Swine Capacity Population
❑ Wean to Feeder
❑ Feeder to Finish
Farrow to Wean 4MO
Farrow to Feeder
❑ Farrow to Finish
❑ Gilts
❑ Boars
Design Current Design Current
Poultry Capacity Population Cattle Capacity Population
❑ Layer ❑ Dairy
❑ Non -Layer 1[] Non -Dairy 1 .1 --:::d �
❑ Other
Total Design Capacityjp
Total SSLW
Number of Lagoons ❑ Subsurface Drains Present ❑ Lagoon Area 10 Spray Field Area
Holding Ponds / Solid Traps. ❑ No Liquid Waste Management System
Discharges & Stream Impacts
1. Is any discharge observed from any part of the operation (If yes, notify DWQ)? ❑ Yes 0 No
Discharge originated at: ❑ Lagoon ❑ Spray Field ❑ Other
a. If discharge is observed, was the conveyance man-made? ❑ Yes AfNo
h. II'discharge is observed, did it reach: ❑ Surface Waters ❑ Waters of the State ❑ Yes No
c. If discharge is observed. what is the estimated flow in galhnin?
d. Does discharge hypass a lagoon sysiorn? ❑ Yes No
2. is there evidence of past discharge from any part of the operation? ❑ Yes', [j No
3. Were there any adverse impacts to the waters of the State other than from a discharge? ❑ Yes NNo
Waste Collection & Treatment
4. is storage capacity (freeboard plus storm storage) fess than adequate? Yes ❑ No
Structure I Structure 2 Structure 3 Structure 4 Structure S Structure 6
Identifier: it
Freeboard (inches): ...............L
1/6/99 Continued on back

Facility umber: 49 — 15� I)ate of Inspection
5. Are there any immediate threats to the integrity of any of the structures observed? (ic/ trees, severe erosion,
seepage, etc.)
6. Are there structures on-site which are not properly addressed and/or managed through a waste management or
closure plan?
(If any of questions 4-6 was answered yes, and the situation poses an
immediate public health or environmental threat, notify DWQ)
7. Do any of the structures need maintenance/improvement'?
8. Does any pact of the waste management system other than waste structures require maintenance/improvement?
9. Do any stuctures lack adequate, g-auged markers with required top of dike, maximum and minimum
liquid level elevation markings?
Waste Application
10. Are there any buffers that need maintenance/intprovetnent?
❑ Yes [J(No
❑ Yes V No
Yes ❑ No
M2Yes ❑ No
❑ Yes %No
❑ Yes L No
i ] . Is there evidence ofover app 'cati n? ❑ Ponding ❑Nitrogen ❑j�
Yes No
•``
12. Crop type ............................................................................._........ 4IV..........................................................
13. Do the receiving crops differ with those designated in the Certified Animal Waste Iviana�=ement Plan (CAWMP)? ❑Yes No
14. Does the facility lack wettable acreage for land application? (footprint)
15. Does the receiving crop need improvement'?
16. is there a lack of adequate waste application equipment?
Required Records & Docurnernts
17. Fail to have Certificate of Coverage & General Permit readily available?
18. Does the facility fail to have all components of the Certified Animal Waste Management Plan readily available?
(ie/ WUP, checklists, design, maps, etc.)
19. Does record keeping need improvement? (ic/ irrigation. freeboard, waste analysis & soil sample reports)
20. Is facility not in compliance with any applicable setback criteria in effect at the time of design?
21. Did the facility fail to have a certified operator in responsible charge?
22. Fail to notify regional DWQ of emergency situations as required by General Permit?
(ie/ discharge, freeboard problems, over application)
23. Did Reviewer/Inspector fail to discuss review/inspection with on-site representative?
24. Does facility require a follow-up visit by same agency`?
❑ Yes ❑ No
❑ Yes X No
❑ Yes • V No
❑ Yes X No
r
❑ Yes No
�Ye yo
ElYes No
❑ Yes tv No
4119cs No
❑ Yes j No
X , El No
0. MD'v1olat-1 on' S;or' - dehci tende5.were note=d du.ring this;visit:. oiu' w.vilfreeeive no furtheir .;
eolrresporideitr;e'aboitt-this visit.; ; ; ; :: ; ; :::: ; ; ; ; ; ; : :
Comments (re_fei- to question #): Explain any YES answers and/or any recoin�endations-or any o_ titer commlents.-_:�-=.
Use -drawin sof facilityto better explain situations. use additional pages as necessa _ _ r
ato w•t,J�1«. T�w�e ,� su,�r ' �1.� comer A� ,
/�' fir - AILfd
v vu7 l ► e e ��u�-a�""�
Ao o rL - A10 Aego
�a l e`_1+.•�
"LSP- �. •�
p: 71te S sLa,7
--
Reviewer/]nspector Name
Reviewer/Inspector Signature: Date: q�-
116199

//I - . - -
Facility Number: of— JC Elate of Inspection I
Adehunal Com�rien
is anal©r Drawings: z� hJoe',
as &uP �&- ,.r to, 41,; 4- c4/
Ir', 4j -
aa- �
r
crm n
7/25/97

Microbac Laboratories, Inc.
FAYETTEVILLE DIVISION IAC #11
817 CASTLE F-klliE STREET NC #37'113
VAYETTEVILLE, 11C; ?030? .� USDA #a% 7
('910) u6,1-1920 / (90) 864-8774 (FAX)
AIR • FUEL • WATER • FOOD • WASTES
CERTIFICATE OF ANALYSIS
r1 . T PNT : NO DFRNP
ADDRESS: Wachovia Suildinq, Suite 714
Fayetteville, Ntt 26-0 ll
CgNTA4_T PERSON: Mr. J. Brow,w
ACCOUNT NUMBER. 9XI4003
:,AMPLR TD:
CERT #25428
DATE PEC'r): 02/12/04 SAMPLPD: 07/17/99
SAMPLED BY: J. 8cown
08LIVbREU 131: 0. browtl
SAMPLE CODE: Wil, St yam, Grab
REFERENCE; BSC Farm 028
1 . 314irmir. — 1 i', #91) 1 i 01,14
2. Downstream — .LD #99WD21085
3. Source, Field 41 #99WS21086
4. Up5troant - IU a99WU21087
S. % ;t,sLs tiuut, D.iL Ax - ID -'r,9 D21033
6. Upstream, Ditch - ID #991,TJ21089
I. Source, Field #2 ID i#99WE21090
8.
DATA REVIEVIED BY:/?•'�-�.,
DATE REPORTED: 02/15/°a
i i i t I i l i 4 f e a i i 4 4 1 4 A 3 1 t 4 4 1 4 i t i 4 1 4 i I. i l f l i I i i i 4 i i# i t . s i 4 1 1 i 0 1 i l 4 I l i[ i i i l i+ i i 4 1 1 4 7 t i l i
A ALYSIS - METHOD 1 2 3 4
w0 -+44+-4+++44,4,4,4,+r4,+4-4+ ++-k+-4+.+4,4,44-44,40 4+4+0.14, +++++4L++++4.4,++t-++L++,L 1,44,&-k 4+-k; 1 -4 -i -k+
COLIFORM, FECAL (per 100 ml.) SM7.8 9222D 52000 31000 100000 9
+j,+i-+4-*A.++44k ..+++4if-f.} •1.+++ +++k+4++4. V4 •+ i+++++4+4*++4+-4+ii-+444,4+4•-4+4-&44, }1}+A -+j. 4.4 y.+
ANALYSIS B 7 8
++++4,++0++i++++4,++++++-4.M+#+++++++++++++i+0+++l.++-F 44,+0•++++dr+++ +++++++#++
COLIFORM, FECA-T,-Tfper 100 ml) SmiS 42222 rt 240000 45 11500000
RECEIVED
Ci%ms'Er5N,ai; _' = Lg5s [hall A14R 0 9 1999
= i�rater than �7�
FaYT�
REG• O1
Uz
PAGE 1 OF 1 FF
i
a ,
nw dm and other Intom7atlon contained on this, and other eocompanyft doWrnerns, represent only the sampla(s) andyzed and is M E M B E R
rendered upon the condtlon that It Is not to be reproduced wholly or in part for advertising or other purposes wkhmn written approval
from the labormory.
USDA -EPA -NIOSH Testing Food Sanitation Consulfing Chemical and Microbiological Analyses and Researdt

HIGH FREEBOARD NOTIFICATION
DATE_/ ME
DWO Contact
Name of Person
contacting DWQ: SCJ — A)d CLll/
Telephone No.(_�
FARM Nome .� 2-q
County &,,
Facility No. (2 7' ' / 5—�
Freeboard level of the Lagoon:
Conditions of the spray fields: _ AW
NARRATIVI=: (Include any instructions given to the farmer at the time of the call)
(A copy of each notification should be forwarded to the 'CAFO BOX' in John Hostys aff'ice
os soon os possible)

Information contained in this database is from non agency sources and is considered unconfirmed.
Farm Emergency Call Form
Farm Number 09 — 155
Farm Name Farm #28 (BOC)
Owner Frist Name
Owner Last Name Browns Of Carolina, Inc.
Q Reporting O Complaint
Source immy Vinson
Date 11-31-2000
Time :30
Call Number 689
Breached
O Yes ONO
Freeboard Level 1 12
Depopulated
O Yes =o
Freeboard Level 2
Overflowed
O Yes ONO
Freeboard Level 3
LQ Issue
10 Yes O No
PermissionToPump
O Yes O NO
Freeboard Level 4
Inudated
O Yes ONO
Freeboard Level 5
Flooded
O Yes O NO
Freeboard Level 6
Pumping Equipment
O Yes ONO
Comments
iter...e.d..by..J.effe.ry..Bxaw!n...........................................................................................................................................................
. .......................................................................................................................................................................................................................
�ztes .gl�Ad��i IK..to..,l.immy..Vin on.....Plan..Q#. QfiQn.�nlust..k7..s.u.hmitlQd...within..2.4...hou.r;

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
Brown's of Carolina, Inc.
Farm #28 (BOC)
PO Box 487
Warsaw NC 28398
Dear Brown's of Carolina, Inc_:
601?W'A
1 •
AM-
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
December 30, 1999
RECEIVED
1 0 2400
FAYETTEVILLE
REG. OFFICE
Subject: Fertilizer Application Recordkeeping
Animal Waste Management System
Facility Number 9-155
Bladen County
This letter is being sent to clarify the recordkeeping requirement for Plant Available Nitrogen (PAN)
application on fields that are part of your Certified Animal Waste Management Plan.
In order to show that the agronomic loading rates for the crops being grown are not being exceeded, you
must keep records of all sources of nitrogen that are being added to these sites. This would include nitrogen
from all types of animal waste as well as municipal and industrial sludges/residuals, and commercial fertilizers.
Beginning January 1, 2000, all nitrogen sources applied to land receiving animal waste are required to
be kept on the appropriate recordkeeping forms (i.e. IRR 1, IRR2, DRY], DRY2, DRYS, SLUR 1, SLUR2,
SLD1, and SLD2) and maintained in the facility records for review. The Division of Water Quality (DWQ)
compliance inspectors and Division of Soil and Water operation reviewers will review all recordkeeping during
routine inspections. Facilities not documenting all sources of nitrogen application will be subject to an
appropriate enforcement action.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Ms. Sonya Avant of the
DWQ staff at [phone] ext. 571.
cc: Fayetteville Regional Office
Bladen County Soil and Water Conservation District
Facility File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617
An Equal Opportunity Affirmative Action Employer
Sincerel
Kerr T. Stevens, Director
Division of Water Quality
'telephone [phone] Fax [phone]
50% recycled/10% post -consumer paper

• . 4' 1 L.
''PLAN OF ACTION (P*A) FOR HIGH FREEBOARD AT ANIMAL FACIUTIES
Facility- _
Number:_ � �S County:
Favility Name: _-•—,---,42
1_-.-_--_
Certified Operator Name: a� �e Optm for d
1. Current liquid levels? in Inches as mewured from the current squid level In the lagoon to the
lowest point on the top art the dam for lagoons w tttout spillways; and from the current liquid level
in the lagoon to the bottom of the spillway for lagoons with spillways.
Structure 1 Struatum 2 Structure 3 Strttdure 4 Structure 5 Structure e
Lagoon NameAdentiffer0Dy- _ r �._._.I
Splltway (Yes or No): ......
Level (inches):
_mss
2, Check ail applicable Iterl1s
Liquid level Is wW* the designed a iAwral haeboaM elevations. of one or more structures..
Five and 30 day Plans of Action are attached- Hydraulic and egmnomic baalancm are within
acceptable ranges_
tom! Llctuid level is within the 25 year 24 hour staim clovaWns for one or more sbuMrss. A 30 day
Plan of Action Is attached. Agmnorrtrc balance is wltNn acceptable range,
�,.. Waste is to be pumped and hauled to off s t+C locafmns. Volume and PAN content of waste to
pumped and hauled Is refiecned in sec *m III tables. included within this plant is a list of the
proposed sites with related fad* minftr(s), number awes and -receiving crop Information.
Contact and secure approval Brom *e Division of Water Quarity gnrgr Ig gM13gftr of WASW
to a site not covered In the fadltty 6 GeMed animal waste rnanagerromt pian.
OPem4on w17l be pariielly or fully depopulated.
- attach a complete schedule with corresponding animal units and dates for depopuiadon
- N animals are to be moved to anotm pefrr ted facility. provide faclllty number, lagoon
freeboard levels and hard population for the recalving facility
3, Earliest possible date to begin land appllcatian of waste:
I hereby ceAify that I have reviewed the Infarmabon ftted above and included wtt n the Mooed Plan
of Actlon, end to the beg of my knmWefte and ability, the information is aeaurtte and eorreat
OwnerlManeger (prMQ
Faoilit '"arlManager (signem)
Page ZR1M0
Phone:_ �O r �� �--1 g� rJ
4�ir� r
6 .d SL9196ZCIG 'ON M s Nffo�2 wa IPL NO 00-LZ-aVA

IV_ pACiLIMS POA OVERALL PAN ®A1.ANCE
w. Total PAN to be land applied (line n from section Il) C 1q-0 lb. PAN
x. Crop's remaining PAN balance pine v from section 111) p `1: ; �; t 1b. PAN
y. Overall PAN balance (w - x) a 1b. PAN
Line y must show as a deficit If line y does not show as a deficit, fist course of action here
including pump and haul, depopulation, hand reduction, otc. For pump A haul and herd
reduction options, recalculate new PAN based an new Information. If new fields are to be
Included as an option for lowering lagoon level, add these fields to Om PAN balance table and
recalculate the overall PAN balance. If animal waste is to be hauled to another pennitt+ed
fooility provide Infarmadon moarding the herd population and lagoon freeboard levels at the
receiving facility.
NfiRttAT1YE:
PCkA (SO Day) V21100
Ri
0 .d G9�96Z016 OSI Xd� 5 MOH A-EE:G NONI 00-G7-I'dYi

PLAN OF ACTION (PoA) FOR HIGH FREEBOARD AT ANIMAL FACIUTIES
Fac}llty Number. Gi - - % S—S _ co UW-
Facility Name -
Certified Operator Name: 4,bC?�d!-rv+ 4 -e �j ^ _ Operator
1. Current liquid level(s) in inches as measured from the current liquid level in the lagoon to the
lowest point on the top of the dam for lagoons without spillways; and from the current liquid level
in the lagoon to the bottom of the spillway for lagoons with spillways.
Strudure 1
Lagoon NameAdentifrer (ID):
Spillway (Yes or Noy
Level (inches): _
2. Check all applicable Items
Sbvcture 2 Structure 3 Structure 4 Structure 5 Structure 5
liquid level is within the designed ctrucUral freeboard elevations. of one or more stnrchures.
Frye and 30 day Plans of Action are attached. Hydraulic and agronomic balances are within
acceptable ranges.
Liquid level is within the 26 year 24 hour storm elevations for one or more structures. A 30 day
Plan of Action is attached. Agronomic balance Is within acceptable range.
Waste is to be pumped and hauled to oft site locations. Volume and PAN content of waste to
pumped and hauled Is refiectad in secdm Ili tables. lnrluded within this plan is a rest of the
proposed sites with related facility nurnber(s), number aces and receiving crop Information.
Contact and secure approval from the Division of Water Quality prig[ ig�rn�r of Waste
to a aloe not covered In Ow fadlitq'a certified animal waste management plan.
Operation vWII be partially or fully depopulated.
- attach a complete schedule with corresponding animal units and dates for depopulation
- if animals are to be moved to another permitted facrTrty, provide facility number, lagoon
freeboard levels and hard population for the receiving facility
3. Earliest possible date to begin land application of waste:
I hereby ceritfy that I have reviewed the formation listed above and included within the attached Plan
of Action, and to the best of my knowledge and ability, the information is accurate and correct:
J `fn M L4 1/A-4
Owner/Manager (pr int)
Fac 1166 'QwnerlManager (signature)
page 2121!00
Phone:�LO
Date` r- '?

PLAN OF ACTION (PoA) FOR HIGH FREEBOARD AT ANIMAL FACILMES
THIRTY (30) DAY DRAW DOWN PERIOD
1. TOTAL PAN TO BE LAND APPLIED PER WASTE STRUCTURE
y1. Structure NamelldenUfler (10):
2. Current liquid volume in 25 yr.r24 hr. storm Storage & structural freeboard
a. current liquid level according to marker inches
b. designed 26 yr124 hr. storm & sttuc tw al freeboard inches
c. line b - line a (inches in red zone) = % inches
d top of dike surface area according to design 3Zd 7 / ftz
(area at below structural fieeboard elevation)
e. linp 2 x line d x 7.48 qW orli ZOV gallons
12 fe
3. Projected volume of waste liquid produced during draw down period
f. temporary storage period wording to stn.rctural design � r days
g. volume of waste produced according to strucfural design V fe
h. actual waste produced — %mmrg-herd # x line g
certified herd # 4
i. 'volume of wash water acrardng to shuctural designrf rc-���l d fe
j. excess rainfall over evaporation according to design fe
k (lines h+ i +i) x 7.48 x 30 s=
litre f
4. Total PAN to be land applied during draw down period
I. current waste analysis dated /-//- P
rn. (lines e + kl x fine I =
1 000
REPEAT SECTION ( FOR EACH WASTE STRUCTURE ON SITE
PDA (30 Day) 2121100 1
gallons
I1:11000 gal.
�-� 3 lb PAN

ll, TOTAL POUNDS OF PAN STORED WITHIN STRUCTURAL FREEBOARD AND/OR 25 YRJ24
HR. STORM STORAGE ELEVATIONS IN ALL WASTE STRUCTURES FOR FACILITY
'I. structure ID: line m =' Ib PAN
2. structure ID: line m lb PAN
3, structure ID: line m = Ib PAN
4. structure ID:
5. structure ID:
6. structure ID:
n. linesl+3+3+4+6+6 r
line m = lb PAN
line m = lb PAN
line m = Ib PAN
�� ` t 3 ib PAN
III. TOTAL PAN BALANCE REMAINING FOR AVAILABLE CROPS DURING 30 DAYDRAW DOWN
PERIOD, DO NOT LIST FIELDS TO WHICH PAN CAN NOT BE APPLIES DURING THIS 30 DAY PERIOD_
o. tract # p. field #
q. crop
r, aces s. remaking
IRR -2 PAN
baiance
L TOTAL PAN
BALANCE
FOR FIELD
column r x a
u.
apphtxttion
window'
'?J.2 M -r
Cn
2 7
7. ,S'
dr--
/ o
CP 6
73
?-U
t
'State current crop ending application date or next cep application beginning date for available receiving
craps during 30 day dram down period
v. Total PAN available for all fields (sum of colurnn t) = �� '� lb. PAN
PDA (311 Day) V21MO 2
i

-"FI:E.24.2M0 16:05 M NCDENR WIRO
---NQ-646 P. 7/10
I
IV. FACIMY'S POA OVERALL PAN BALANCE
- w. Total PAN to be land applied (line n from section ll) 1b. PAN
x. Crop's remaining PAN balance (line v from section III) = Ib. PAN
y. Overall PAN balance (w - x) = lb. PAN
Line y must show as a deficit If line y does not show as a deficit, list course of action here
including pump and haul, depopulation, herd reduction, etc. Forpurnp & haul and herd
reduction options, recalculate new PAN based on new Information. 9 new fields are to be
included as an option for lowering lagoon level, add these fields to the PAN balance table and
recalculate the overall PAN balance. If animal waste is to be hauled to another permitted
facility provide information regarding the hard population and lagoon freeboard levels at the
receiving facility.
►j
PDA (30 Day) 41 atl 3

PLAN OF ACTION (POA) FOR HIGH FREEBOARD AT ANIMAL FACiLMES
THIRTY (30) DAY DRAW DOWN PERIOC
-� - I. TOTAL PAN TO SE LAND APPLIED PER WASTE STRUCTURE -
`� 1. Structure Namelldentifier (113):
2. Current liquid volume in 28 yr.124 hr. storm Storage & structural freeboard
a. currant Ilquid level according to marker A inches
b. designed 25 yr./24 hr. storm & structural freeboard inches
c, line b line a (inches in red zone) = inches
d. top of dike surface area according to design
(area at below structural freeboard elevation) f ��
e. gaqj x line d x 7.48811--le9= gallons
12
3. Projected volume of waste liquid produced during draw down period
f temporary storage period according to strucWr2j design days
g. volume of waste produced atx arding to structural design �P fe
h. actual waste produced current herd x fine g = fe
certified herd #
i. -volume of wash water according to stiu:tural design
j. excess rainfall over evaporation according to design
k (lines h t i +I) x 7.48 x 30 days
line f
4. Total PAN bo be laud applied during draw down period
i. current waste analysis dated % ltl - �v
m.(lines e + 1c x litre I
1000
REPEAT SECTION I FOR EACH WASTE STRUCTURE ON SITE
POA (SO Day) 2121100
fly
2gailons
/- �'_ V1000 gal.
2 3,ya Ira PAN

w1
IV. FACI1-MrS PoA OVERALL PAN BALANCE
w. Total PAN to be land applied (tine n from section il) = _-*1-6 i Ib. PAN
x. Crop's remaining PAN balance (line v from section 111) _ 1-3 4S--6 _ ib. PAN
y. Overall PAN balance (w - x) = (z6/I • Ib. PAN
Line y must show as a deficit If line y does not show as a deficit, list course of action here
including pump and haul, depopulation, herd reduction, etc. For pump & haul and herd
reduction options, recalculate new PAN based on new Informatiom if new fields are to be
included as an option for lowering lagoon level, add these fields to the PAN balance table and
recalculate the overall PAN balance. If animal waste is to be hauled to another permitted
facility provide information regarding the herd population and lagoon freeboard levels at the
receiving facility.
NARRATIVE:
PDA (30 Day) x121100 3
r

PLAN OF ACTION (PoA) FOR HIGH FREEBOARD AT ANIMAL FACILITIES
Facility Number: �q -- - I 5- County:0�y4lc ,
Facility Name: _ C Z-�r _
Certified Operator Name: R& cf: ct 1 -e- 1C
Operator #
1. Current liquid level(s) in inches as measured from the current liquid level in the lagoon to the
lowest point on the top of the dam for lagoons without spillways; and from the current liquid level
in the lagoon to the bottom of the spillway for lagoons with spillways.
Structure 1 Structure 2 Structure 3 Structure 4 Structure 5 Structure 6
Lagoon Name/identifier (ID): 1
Spillway (Yes or No): CCI I l/
�-
t�� E
i
Level (inches): /� � -Y i 200
2. Check all applicable items FAYETTEVILLE
REG. OFFICE
Liquid level is within the designed structural freeboard elevations of one or more structures. Five
and 30 day Plans of Action are attached. Hydraulic and agronomic balances are within
acceptable ranges.
iquid level is within the 25 year 24 hour storm elevations for one or more structures. A 30 day
Plan of Action is attached_ Agronomic balance is within acceptable range.
Waste is to be pumped and hauled to off site locations. Volume and PAN content of waste to
pumped and hauled is reflected in section III tables. Included within this plan is a list of the
proposed sites with related facility number(s), number acres and receiving crop information.
Contact and secure approval from the Division of Water Quality prior to transfer of waste
to a site not covered in the facility's certified animal waste management plan.
Operation will be partially or fully depopulated.
- attach a complete schedule with corresponding animal units and dates for depopulation
- if animals are to be moved to another permitted facility, provide facility number, lagoon freeboard
levels and herd population for the receiving facility
3. Earliest possible date to begin land application of waste: S.� —/ - o
I hereby certify that I have reviewed the information listed above and included within the attached Plan
of Action, and to the best of my knowledge and ability, the information is accurate and correct.
-$ � a Lryva� �n�►_ i,rsaN Phone: �C/b -214 -AW
acility Owner/Manager (print)
Date: c - 27 Q
Owner/Manager (signature)
PoA Cover Page 2121100

PLAN OF ACTION (PoA) FOR HIGH FREEBOARD AT ANIMA""'CEIVIED 1TIES
THIRTY (30) DAY DRAW DOWN PERIOD
I. TOTAL PAN TO BE LAND APPLIED PER WASTE STRUCTURE R1 4 y i 2000
1 aYMT
1. Structure Namelidentifier (ID):�eG• EMLLZ
2. Current liquid volume in 25 yr.124 hr. storm storage & structural freeboard
a. current liquid level according to marker
b. designed 25 yr./24 hr. storm & structural freeboard
c. line b - line a (inches in red zone) =
d. top of dike surface area according to design
(area at below structural freeboard elevation)
e. line c x line d x 7.48 gallons =
12 ft3
A, r inches
/tel inches
-7
/- inches
-3z6 714 ftz
3_ Projected volume of waste liquid produced during draw down period
If 2 gallons
f. temporary storage period according to structural design /9'1) days
g. volume of waste produced according to structural design /.- �`3 ft3
h. actual waste produced = current herd # x line g = 4<,S.Sr/ ft3
certified herd #
i. volume of wash water according to structural design
j. excess rainfall over evaporation according to design
k. (lines h + i +i) x 7.48 x 30 days =
line f
4. Total PAN to be land applied during draw down period
I. current waste analysis dated 4- r i-00
m. lines e + k x line I =
1000
REPEAT SECTION I FOR EACH WASTE STRUCTURE ON SITE
PoA (30 Day) 2121/00 1
— D �- ft3
ft3
gallons
1. f lb/1000 gal.
7 Ib PAN

II_ TOTAL POUNDS OF PAN STORED WITHIN STRUCTURAL FREEBOARD AND/OR 25 YR.124
HR. STORM STORAGE ELEVATIONS IN ALL WASTE STRUCTURES FOR FACILITY
1. structure ID: / line m = -,) 73,-7 Ib PAN
2. structure ID: line m = Ib PAN
3. structure ID: line m = Ib PAN
4. structure ID: line m = Ib PAN
5. structure ID: line m = Ib PAN
6_ structure ID: line m = Ib PAN
n. lines 1+2+3+4+5+6 = Ib PAN
III. TOTAL PAN BALANCE REMAINING FOR AVAILABLE CROPS DURING 30 DAYDRAW DOWN
PERIOD. DO NOT LIST FIELDS TO WHICH PAN CAN NOT BE APPLIES DURING THIS 30 DAY PERIOD.
o. tract #
p. field #
q. crop
r_ acres
s_ remaining
IRR -2 PAN
balance
(lb/acre)
t. TOTAL PAN
BALANCE
FOR FIELD
(Ibs.)
column r x s
u_ application
window'
4'7 3 7
4-32-
Z 5 5-
-% 11
7 31
G
6.0
-) ?
S,4a
AAS
7 3'7
13 AA G
!
r
02
(a l
6
-.
'State current crop ending application date or next crop application beginning date for available receiving crops
during 30 day drawn down period
v. Total PAN available for all fields (sum of column t) = 15-4 �4' Ib. PAN
PoA (30 Day) 2121100 2

IV. FACILITY'S PoA OVERALL PAN BALANCE
w. Total PAN to be land applied (line n from section 11) _ �? 3 7 Ib. PAN
x. Crop's remaining PAN balance (line v from section ill) _ /S -o xe Ib. PAN
y. Overall PAN balance (w - x) = /,-z -Aq / Ib. PAN
Line y must show as a deficit. 1f line y does not show as a deficit, list course of action here
including pump and haul, depopulation, herd reduction, etc. For pump & haul and herd
reduction options, recalculate new PAN based on new information. If new fields are to be
included as an option for lowering lagoon level, add these fields to the PAN balance table and
recalculate the overall PAN balance. If animal waste is to be hauled to another permitted
facility provide information regarding the herd population and lagoon freeboard levels at the
receiving facility.
NARRATIVE:
0
PoA (30 Day) 2129100 3

11-0
i a it THU
■
■■
■
5:11 PM BROWN S
FAX NO. 9102961675
P. 1
QV PLAN OF ACTION (PoA) FOR HIGH FREEBOARD AT ANIMAL FACILITIES
Facility Number: - 1S, County_ _/�r✓1in _
Facility Name, _06 d- C
Certified Operator Name: D W44L *X-414-4 Operator #
Current liquid level(s) in inches as measured from the current liquid level in the lagoon to the
lowest point on the top of the dam for lagoons without spillways; and from the current liquid level
in the lagoon to the bottom of the spillway for lagoons Wilk spillways.
Lagoon Namelldentifier (ID):
Spillway (Yes or No):
Level (inches):
Structure 1 Structure 2 Structure 3 Structure 4 Structure 5 Structure 6
_ &b -
2. Check all applicable items
—aaa-2-rrzoae----
Fn-�,i IIILLE
REG. OFFICE
Liquid level is within the designed structural freeboard elevations of one or more structures. Five
and 30 day Plans of Action ar? attached_ Hydraulic and agronomic balances are within
acceptable ranues.
iquid level is within the 25 year 24 hour storm elevations for one or more structures. A 30 day
Plan of Action is attached. Agronomic balance is within acceptable range.
Waste is to be pumped and hauled to off site locations. Volume and PAN content of waste to
pumped and hauled is reflected in section III tables. Included within this plan is a list of the
proposed sites with related facility number(s), number acres and receiving crop information.
Contict ind SCCcum approyal from lily Plyl9ign of Water Quality Prior to transfer of waste
to a site not covered in the facility's certified animal waste management plan.
Operation will be partially or fully depopulated.
- attach a complete schedule n'ith corresponding animal units and dates for depopulation
if animals are to be moved tL another permitted facility, provide factilty number, lagoon freeboard
levels and herd population for the receiving facility
3_ Earliest possible date to begin land application of waste: �5 —/ - o =' _
I hereby certify that 1 have reviewed the Information listed above and included within the attached Plan
of Action, and to the best of my knowle1ge and ability, the Information is accurate and correct.
..-s &'.< CG4na L. I
0 vlW�h ►r..r-sa-
acility Owner/Manager (print)
FalVf'ty Owner/Manager (signature)
PoA Cover Page 2!21100
Phone: 216 - 244 - /8"4d _
Date:

APR«27-00 T lli_i 5:11 PM BROWN FAX NO, 9102961675 P. 2
PLAN OF ACTION (PoA) FOR HIGH FREEBOARD AT ANIMAL FACILITIES
THIRTY (30) DAY DRAW DOWN PERIOD
1. TOTAL PAN TO BE LAND APPLIED PER WASTE STRUCTURE
1. Structure Name/Identifier (ID): J!( '
2. Current liquid volume in 25 yr -/24 hr. storm storage & structural freeboard
a. current liquid leYel a000rding to morhgr
b. designed 25 yr.124 hr. storm & structural freeboard
c- line b - line a (inches in red zone) _
d. top of dike surface area according to design
(area at below structural freeboard elevation)
e. line c x line d x 7.4$a� --
12 , Il9
inches
Z- inches
Z,. -r inches
320 7/ C ft2
_- 4r4,71 ?__ gallons
3. Projected volume of waste liquid produced during draw down period
f. temporary storage period according to structural design D days
g. volume of waste produced according to structural design /• / ft3
h. actual waste produced = current herd # x line g = y�j�1 ft3
certified herd #
i, volume of wash water according to structural design
j. excess rainfall over evaporation according to design
k. (lines h+ 1 +i) x 7-48 x 30 days =
line f
4, TOW PAN to be land applied during draw down period
I- current waste analysis dated 4 - ► 7--d0
m- (lines e + k) x line l
1000
REPEAT SECTION I FOR EACH WASTE STRUCTURE ON SITE
POA (30 Day) 2121100 1
V r fe
An el.,4-1 ft3
gallons
I. V lb11000 gal.
A13-7 Ib PAN

27-00 T11U '/ !M BROWN 1'l0. 9 1 2 9;•1161J F. 3
Il. TOTAL POUNDS OF PAN STORED WITHIN STRUCTURAL FREEBOARD AND/OR 25 YRJ24
HR. STORM STORAGE ELEVATIONS IN ALL WASTE STRUCTURES FOR FACILITY
1- structure ID: / line m = -,a ?3 7 Ib PAN
2. structure ID: line m
Ib PAN
3,
structure 1D:
lime m = lb PAN
4-
structure ID:
line m = Ib PAN
5.
structure ID:
line m = Ib PAN
6.
Wruotufq 1D:
line rn = ----- _---.. lb PAN
n.linesl+2+3+4+5+6
4T40
Ib PAN
Ill. TOTAL PAN BALANCE REMAINING FOR AVAILABLE CROPS DURING 30 DAYDRAW DOWN
PERIOD.
DO
NOT LIST FIELDS TO WHICH PAN CAN
NOT BE APPLIES DURING THIS 30 DAY PFRIon_
o. tract #
p. field # q- crop
r. acres s. remaining
1RR-2 PAN
balanceb
(Ib/acre)
t. TOTAL PAN
iBALANCE
column r x a
u- application
window'
.. 1
-- T ``n
-
r•
`` �r
/l-4-6,5-
A- 2— -4V J
411
*e- 0
7 31
/e,"G
o. v 7 7
4T40
rr
w?,Sn
06M 6
. L
3$2
'State current crop ending application date or next crop application beginning date for available receiving crops
during 30 day drawn down period
v. Total PAN available for all fields (sum of column t) = /S-4 lb. PAN
POA (30 Day) 2121100 2

A?R-27-OD THU x:12 PM B.R0WN S FAX NO. 9102961675 F. 4
IV. FACILITY'S PoA OVERALL PAN BALANCE
w. Total PAN to be land applied (line n from section 11) = � 7 3 7 Ib. PAN
x_ Crop's remaining PAN balance (line v from section 111) /Sro 2-*- Ib. PAN
y. Overall PAN balance (w - x) = _ /-Z ;q / Ib. PAN
Line y must show as a deficit. if line y does not show as a deficit, list course of action here
including pump and haul, depopulation, herd reduction, etc. For pump & haul and herd
reduction options, recalculate new PAW 6ased on new information. If new f ells AM tb hA
included as an option for lowering lagoon level, add these fields to the PAN balance table and
recalculate the overall PAN balance. If animal waste is to be hauled to another permitted
facility provide information regarding the herd population and lagoon freeboard levels at the
receiving facility.
NARRATIVE,
0
PoA (3D Day) 21211D0 3

4. P. 01
Al
AUG -04-00 FR 08:21 AM BROWS OF CAROLINA! FAX NO. 2961AR
24
'BROWN'.
OF CAROLINA
910,29"168 -Fax
ax
A*
Fa3c page=
P.M CQ
OUrgent ElFar Review 0 Plaase Comment oPieria Reply jiffi, Recycle
0 CarnrneeAju
Subject Lagoon Levels Update
The following lagoon is within the 19" of freeboard as of August 3. 2000.
it
Farm # 28
We received approximately 3* of rain within a 30 minute period In of action
TiI
is to apply land applications as soon as the rains subside and �12 longer
saturated. Please call if you wish to discuss these lagoons or the'a—,;-.isUnderway to
alleviate this high level. w -V ttz
Gus Simmons 910-296-1800 (Off -ice)
Glenn Davi:; 910-296-1600 (Office) 910-2904)=Wobille)

AUG -04-00 FRI 08:21 AN BROWN'S OF CAROLINA! FAX NO. 286133 4�. � P. 02
PLM OF ACTION (POA) FOR HIGH FREEBOARD AT ANI S
30 DAY DRAW DOWN PERIOD
I. TOTAL PAN TO BE LAND APPLIED PER WASTE STRUCTURE
1. Struclure Narne/Identifier 013): BOC #28
2. Current liquid volume in 25 yr.tV' hr. storm storage $ structural freeboaijd;a�
a. current liquid level according to marker 18.4 inches
b. designed 25 yrJ24 hr. storm & structural freeboard r - 19.5 inches
c. line b - line a (nches in red zone) = 1.5 Inches
d_ top of dike surface area according to design..
(area at below structural freeboard elevation) ;i :, 32t3D8D
i
e. line 02 x line d x.7.48 gallons/ft33t1t868U gallons
x gallons/WA
3. Projected volume of waste liquid; produced during draw down period
f. temporary storage period according to structural design I 180 days
g. volume of waste produced according to structural design 422866.1 Ift3
h. current herd # 4000 certified herd # 4000
actual waste produced - eugpnt herd # x line g. _ ° iI22966 ft
certified herd
1. volume of wash water according to structural design ,,-� , �� �- 0 ft3
K�. _Y
J. excess rainfall over evaporation according to design 191333.3 ft3
1 �^
k. {lines h + i + t) x 7.48 x 30 days/line f= n '=� 765827 gallons
4. Total PAN to be land applied during draw down period
I. current waste analysis dated 7/21100 1.58 Ibs/1080 gal.
rn. ((lines e + k)/1000) x lirie 1= �, ,:1608.8 lbs. PAN
a
.k1
REPEAT SECTION II FOR EACH WASTE STRUCTURE ON SITE.
(Click an the next Structure tab shown below);;
PoA (30 Day) 2121/0L , .<<

AUG -04-00 FRI 08.21 AM
IT
up
BROWN'S OF CAROLINA! FAX NO. 2961333 P. 03
�34..`.l�' e
Y
•I
n. lines 1 +2+3+4+5+6= t2,1608.8 Ib PAN
Ill. TOTAL PAN BALANCE REMAINING FOR AVAILABLE CROPS DURING 30 QAY DRAW DOWN
PERIOM nO NOT LIST FIELDS TO WHICH PAN CANNOT BF APPLIFD DIIRIN&TWIS 30 DAY PERIOD.
o. tract #
p. Geld # q. crop
Aid..
11. TOTAL POUNDS OF PAN STORED WITHIN STRUCTURAL FREEBOARD ANDlOR 25 YRJ24
HR. STORMS
STORAGE ELEVATIONS IN ALL WASTE
STRUCTURES FOR FACIUTY
35.66
..4 93.1
4737
1.
St.mctum ID: BOC #28
line m = ;�� S Ib PAN
2_
Structun: ID:
line m = lb PAN
4.25
35.82
152.2
3.
Structum ID:
line m = >6-P lb PAN
35.70
:118.5
j
s
4.
Structure ID:
line m = ,h is�� Ib PAN
-''419.2
4737
6 Bermuda Grazed
1.33
171.11
,,
5.
St, cturc? ID:
line m = Ib PAN
57.60
100.2
4737
6,
Structure: ID:
line m = c Ib PAN
n. lines 1 +2+3+4+5+6= t2,1608.8 Ib PAN
Ill. TOTAL PAN BALANCE REMAINING FOR AVAILABLE CROPS DURING 30 QAY DRAW DOWN
PERIOM nO NOT LIST FIELDS TO WHICH PAN CANNOT BF APPLIFD DIIRIN&TWIS 30 DAY PERIOD.
o. tract #
p. Geld # q. crop
r- acres
s. remaining IRR- t TOMPAN ;- u- 5F F I mija window'
2 PAN bakm" BAIlItRP.'E Mk'i
edmnn r x $
4737
1 Bermuda Grazed
2.61
35.66
..4 93.1
4737
2 Bermuda Grazed
4.93
38.26
188.6
4737
3 Bermuda Grazed
4.25
35.82
152.2
4737
4 Bermuda Grazed
3.32
35.70
:118.5
4737
5 Bermuda Gazed
3.04
137.88
-''419.2
4737
6 Bermuda Grazed
1.33
171.11
227.6
4737
7 Bermuda Grazed
1.74
57.60
100.2
4737
8A Bermuda Grazed
3.03
90.24
�73.4
4737
813 Bennuda Grazed
4.02
98.69
='; =+396.7
4737
9 Bermuda Grazed,
1.56
21.49
4'- 33.5
4737
10 Bermuda Grazed
1.78
29.21
:;;� . X52.0 E
4737
11 Bermuda Grazed
4.44
145.05
x'1844:0
4737
12 Bermuda Grazed
5.84
248.18
-1449-4
4737
13 Bermuda Grazed
5.65
189.94
+ 10732
4737
13 Bermuda Grazed
4.27
157.16
871.1
4737
15A Bermuda Grazed
2.80
214.57
600.8
4%37
15B Bermuda Grazed
2.80
264.54
740.7
'State current crop ending application date or next crop application beginning date fair;4vailable
receiving crop`. during 30 day draw down period.
v. Total! PAN available for all fields (sum of column t) z !%342 lb. PAN
IV. FACILITY': PoA OVERALL PAN BALANCE rf'
w. Total PAN to be land applied (line n from section II) _ -41605.8 Ib. PAN
POA (30 bay) 2121,'00

AUG -04-00 FRI 08:21 AM BROWN'S OF CAROLINA!
FAX NO. 2961333
x. Crop); remaining PAN balance (line v from section 111)
y. Overall PAN balance (w . x) =
•; .t`7234.2 Ib. PAN
-5625 1b. PAN
P. 04
Line y must show a., a deficit. If line y does not show as a deficit. list course of action here including pump and
haul, depopulation, herd reduction, etc. For, pump & haul and herd reduction options; recalwlate new PAN
based on new information_ If new fields are'to be included as an option for lowering oon level. acid these
fields to the PAN balanca table and recalculate the overall PAN balance. If animal waste Is to be hauled to -
another perm.ded facility, provide Information regarding the herd population and lagoon freeboard levels at the
r, eceivingfac+Ei��. _
NARRATIVE.
�tL
^3
.3
dig,•
� f
PoA (30 Day) 2/21100

MAY- 8-00 MON 10:38 AM BROWN S
r•
65 Hwy 24 Ewa
Pd Bax 487
Warsaw, NG 20398-0487
Voice: (910) 298.1 Soo
Fax: [phone]
FaX
To.- %-.Nl 1[ L
From:
FAX NO, 9102961675
P. 1
BRowrv's
OF CAROLINA
Fara Payoal
Pholm -- Qatm = Qj (Zn� — - — --
Roz CC:
❑ Urvent ❑ For Review ❑ Please Comment ❑ Please Reply ❑ Plazas Recycle
e Comment=
0 Pagel

MAY- 8-00 MON 10:38 AM BROWNS FAX NO. 9102961676 P, 2
....,-..�.... ��...,�. � __ �..._ �........ .... uu....ru �.r.:..s_.:_�a- �i�6i►L��dL�ic�^'M'^Slfllliii�.:
1
To: DEHNR — Fayetteville Region
From. Brown's of Carolina, Inc.
Subject: Lagoon Levels Update
I =-
To:
J s
The following lagoon is no longer within the 19' freeboard as of May 6, 2000.
Farm # 28
Gus Simmons 910-296^1800 (Office)
Glenn Davis 910-296-1800 (Office) 810-290-0366 (Mobile) ,
BROWN'S OF CAROLINA. INC.
7Bs HWY 24 EAST • P_O. BOX 487 • WARSAW, N.C. 28393 • PHONE [phone]

. State of North Carolina
Department of Environment
and Natural Resources
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
CERTIFIED MAIL.
RETURN RECEIPT REQUESTED
Brown's of Carolina, Inc.
Farm #28 (BOC)
PO Box 487
Warsaw NC 28398
Dear Brown's of Carolina. Inc.:
•
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
July 3, 2000
3 2000
FAN -E i I I L E
REG. OFFICE
Subject: Notification for Wettable Acre Determination
Animal Waste Management System
Farm #28 (BOC)
Facility Number 9-155
Bladen County
A letter dated January 15, 1999 was sent to advise you about concerns associated with Certified Animal
Waste Management Plans and the method by which the irrigated acres within the plans were calculated_ Only
the acres that are wetted can be credited in the waste management plan as receiving waste application. Any
acreage within the plan that can not be reached by waste application equipment can not be used as part of your
plan.
An evaluation by Jeffery Brown on 2/9/99 was made to review the actual number of acres at your facility
that receive animal waste during land application. The evaluation of your facility has yielded one of the
following two results as indicated by the box marked with an "X".
Category 1:
❑ The evaluation of your facility could not be completed due to a lack of information. Please
contact your Technical Specialist to assist in providing John Hasty the necessary
information to potentially exempt your facility from undergoing a complete wettable acre
determination. Please submit this information to John Hasty, at 225 Green Street, Suite
714, Fayetteville, NC 28301, within in 90 days of the receipt of this letter. If you have any
questions please contact John Hasty at [phone]. If within 90 days you are unable
to provide John Hasty with the information you are automatically required to complete
a Wettable Acre Determination as described by Category 2 below, within 180 days
of receipt of this letter.
1617 Mail Service Center, Raleigh, Forth Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

Notification for Wettable Acre Determination
Animal Waste Management System
Page 2
Category 2.-
Your
:Your facility has been identified by the Department of Environment and Natural Resources
as a facility that may have overestimated the number of acres actually receiving animal
waste. Therefore, some or all of your fields may be exceeding the allowable loading rates
set in your Certified Animal Waste Management Plan.
In order to resolve this issue, please contact a designated Technical Specialist to have him
or her conduct.a Wettable.Acre.Determination for your facility. The Technical Specialist must
be one that has been approved by the Soil and Water Conservation Commission to conduct
Wettable Acre Determinations. Many Technical Specialist with the N.C. Cooperative Extension
Service, the Soil and Water Conservation Districts, the Natural Resources Conservation
Service, and the Division of Soil and Water Conservation have received this special
designation. You may also contact a private Technical Specialist who has received this
designation, or a Professional Engineer.
All needed modifications to your Animal Waste Management System must be made and
the Wettable Acres Determination Certification mast be returned to DWC within the next
180 days. If the needed modifications are not made and if the form is not returned within the
required time, DWQ will be forced to take appropriate enforcement actions to bring this facility
into compliance. These actions may include civil penalty assessments, permit revocation,
and/or injunctive relief.
Once a Wettable Acre Determination has been completed, a copy of the attached Wettable
Acre Determination Certification must be submitted to the address listed on the form. Please
note that both the owner and the Technical Specialist must sign the certification. A copy of all
the Wettable Acre Determination documentation that applies to your Waste Utilization Pian
must be kept at your facility. DWQ and the Division of Soil & Water Conservation Staff will
review all documentation during their annual visit of your facility. An additional copy must by
kept on file at the local Soil & Water Conservation District Office. Please note that if you install
or modify your irrigation system, a designated Irrigation Specialist or a Professional Engineer
must also sign the Wettable Acre Determination Certification.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Sonya Avant of our
Central Office staff at [phone] ext. 571 _
Sincerely,
Kerr T. Stevens
cc: Fayetteville Regional Office
Bladen County Soil and Water Conservation District
Facility File

1Y1Fii- L-UU !Vi i - D 0 r DriVgA i. L
May 2, 2000
To: DEHNR — Fayetteville Region
From: Brown's of Carolina, Inc.
Subject: Lagoon Levels Update
The following lagoon were less than 19" as of April 29, 2000.
Farm # 13 is.
Farm # 28 16' 6 g E S S
Farm # 30 15' y
RECEiVED
QJ, Y 2 2000
FAY6���
REd, OFFIt�
Please call it you wish to discuss these lagoons or the actions underway to alleviate
these high levels_
Gus Simmons 910-298-1800 (Office)
Glenn Davis 910.296-1800 (Office)
910-290-0366 (Mobile)
BROWN'S OF CAROLINA. INC.
785 HWY 24 EAST - P.O. SOX487 • WARSAW, N.C. 28398 - PHONE [phone]

mrli- i-UU Luz i•7U rm
S5 Hwy 24 East
PQ Box 487
Watmw, NC 28.9&0487
Voice: (910) 29&1800
Fax [phone]
Fax
Davffil J
rnA Ru. JIUZ501Q/J r. I
BROWN'
ReQe/vfo;�L
OF CAROLINA
?00D
R Ce --VI
Tot From. �S
Fara Z�-JQ�j Pageet
Phone@ Data:
RarCC. -
0
C:
© Urgent 0 For Review 0 Please Comment la Please Reply 0 Please Recycle
e Gonnrentst
0 Page 7

DIVISION OF WATER QUALITY
October 2, 2000
MEMORANDUM
TO: DWQ Files
Fayetteville Regional Office
FROM: Paul Rawls /
RE: Brown's of Carolina Farms
Fayetteville Region
Attached letter faxed to Mr. Guss Simmons on September 28, 2000.
rl

J4
`,
aY ^t e
'=' y NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
DIVISION OF WATER QUALITY
September 27, 2000
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Guss Simmons
Brown's of Carolina, Incorporated
Post Office Box 487
Warsaw, North Carolina 28308
SUBJECT: Continuing High Freeboard Levels
Brown's of Carolina Swine Farn>Es
Fayetteville Region
Dear Mr. Simmons:
This letter is to serve as follow-up to a discussion that was held with Mr. Glenn
Davis with Brown's of Carolina, John Hasty, Environmental Specialist, Division of
Water Quality and myself September 26, 2000 concerning high freeboard levels
at several of the Brown's of Carolina (BOC) swine farms located in the
Fayetteville Region.
The Water Quality Section of the Fayetteville Regional Office has performed a file
review of several of the BOC swine farms in this region and has confirmed that
freeboard problems continue to be a issue throughout the 2000 Spring and
Summer cropping window. These farms were also noted to have had freeboard
problems during previous years as well.
Our review identifies at a minimum farms 13, 28, 29 and 30 have had ongoing
problems and at last report freeboard levels remain less than that required. This is
particularly disturbing as weather patterns this year, especially during late spring
and summer, have been in my opinion somewhat normal. During our discussion
your staff relayed efforts to improve waste management and the desire of BOC to
comply with the rules and regulations pertaining to swine farms.
-continued-
i�_ ll p
2 0 I 0
1617 MAIL SERVICE CENTER, RALEIGH, NORTH CAROLINA 27699-1617
website: h2o.enr.state.nc.us PHONE [phone] FAX [phone]
AN EQUAL OPPORTUNITY / AFFIRMATIVE ACTION EMPLOYER - 50%n RECYCLED/10% POST -CONSUMER PAPER

Mr. Simmons
September 27, 2000
Page 2 of 3
During the meeting I asked that BOC furnish the Fayetteville Regional office information on or
before October 4, 2000: (The following list may contain items not requested during the meeting)
- For each farm noted above please explain what events have lead to freeboard level
noncompliance this year and if BOC evaluated the reduction in the number of swine at
each -farm -as -a means -to maintain compliance prior to becoming noncompliant.
-It appears that the 30 day Plan of Action submitted 911/00 for farm #28 W411 not be met: Please
explain why. If other BOC farms have not met or are projected at this time not to meet
other Plans of Action please provide similar explanations and information by October 4,
2000.
-Please provide all freeboard levels for the aforementioned farms for this year from 1/1/2000 to
present.
-Please provide the most up to date waste management plans for the aforementioned farms.
-Please provide all records pertaining to waste application for the aforementioned farms to include
waste analysis, waste application and nutrient balances for the farms noted during 2000.
-For the farms noted please also provide a detailed plan to ensure compliance with each waste
utilization plan for the remainder of this cropping cycle and the next cropping cycle
ending in early 2001.
-Please also provide any lease agreements for additional land that could potentially be used in
alleviating problems at the farms noted.
It is also understood that waste was or is in the process of being pumped and hauled from farm
#13 to farm #14. Please be advised that "prior" to pumping and hauling of waste from one farm to
another a detailed analysis should be performed to determine if the farm receiving the waste can
adequately accept the waste and that the certified waste management plan has been revised
accordingly. This office should be aware of such action prior to pumping and hauling and approve
such action prior to commencement of the activity. Further, such measures should be considered
prior to noncompliance not only as a remedy for high freeboard emergencies.
This letter is to also acknowledge receipt of a FAX from Mr. Kevin Weston today (7127/00). The
FAX entitled "Detailed Plan of Action" outlined actions taken or are in process to address farm
#28 problems. The FAX includes the section "2. Emergency Pump and Haul", in this section Mr.
Weston outlines that a pump and haul activity will be initiated to bring the freeboard level to a
compliant level. In a follow-up call to Mr. Weston today (7127/00) it was discovered that details
of this pump and haul operation have not yet been finalized. As noted above a detailed analysis

Mr. Simmons
September 27, 2000
Page 3 of 3
should be performed to determine if the farm receiving the waste can adequately accept the waste
and the certified waste management plan is revised accordingly. This office should receive such
evaluation and revised plan prior to the initiation of the pump and haul process.
Please be advised that the receipt of this FAX does not absolve BOC from failing to meet
the 30 day POA for farm #28 submitted 911/00.
The FAX outlines that "Animal Flow Manipulation" will be employed to also address farm #28
problems and that "Brown's of Carolina has adopted a policy which states that "no animal will be
placed on any farm with less than compliant levels of freeboard". The FAX also indicates that "no
replacement breeding stock will be sent to the farm". Please provide how many head of stock
have not been sent to farm #28 as a result of this policy during 2000. The FAX further states that
BOC will maintain this policy until compliant freeboard levels are attained. I urge BOC to
consider expanding this policy not to restock animals until BOC has determined that the entire
waste utilization plan can be met throughout the current and if necessary the following crop cycle.
This office views the freeboard levels at these farms critical as we are still in hurricane season.
Brown's of Carolina should make every effort to lower lagoon levels to achieve compliance and
to avoid preventable environmental impact.
Please be advised that furnishing the requested information in no way absolves BOC of any
violation past or future and the compliance history of these and other BOC farms is under review
to determine what action, if any, should be initiated by this office.
If you have questions or comments regarding this letter please do not hesitate to contact me at
[phone].
Sincerely,
'Paul E. Rawls
Water Quality Regional Supervisor
cc: Coleen Sullins, DWQ
Dennis Ramsey, DWQ
DWQ FRO Files BOC Farms 13, 28,29,30
DWQ Central Files
O 155

.................................................1 1
785 HM. 24
�BRO
,.
W � it � , \ PO Box 487 nasi } 72001 f
Warsaw, NC 2&399-0487
OF CAROLINA
Fw .
August 1, 2001
Mr. Paul Sherman
Fayetteville Regional Office
225 Green Street, Suite 714
Fayetteville, NC 28301-5043
Dear Paul,
I have recently completed a review of the pumping records for the Brown's of Carolina farms.
There are some incidences of over application on individual pulls.
2000 Winter pumping over application by pull:
Farre
Facility No.
County
Hydrant
PAN in WUP
Over a tication
3510
82-442
Sampson
17
117 lbs.
2lbs.
18
117 lbs.
11 lbs.
3111
82-340
Sampson
06
141 lbs.
14 lbs.
07
141 lbs.
13 lbs.
08
141 lbs.
2 lbs.
3728
09-155
Bladen
16
50 lbs.
2.42 lbs.
729, 3093
09-153
Bladen
07
129 lbs.
1.94 lbs.
3094
78-085
Robeson
04B
100 lbs.
5.53 lbs.
2001 Summer pumping over application
by pull:
Farm
Facility No,
County
Hydrant
PAN in WUP
Over application
3514
82-443
Sampson
23A -
147 lbs.
6.85 lbs.
2537, 2538
82-466
Sampson
07A
260 lbs.
2 lbs.
For the Summer 2001 pumping a new lagoon analysis will be taken in August.
I would be happy to answer any questions that you have. I can be reached at 910-296-1800 ext. 217.
Sincerely,
David Nordin
Land & Nutrient Management

APR -12-2001 THU 08:38 AH BROWN'SOFCAROLINA 9102966166
P. 03
ROWN"s
OF I
CAROLINA
I
April i0, 2001
Mr. Paul Rawls
Water Quality Regional Supervisor
N C Dept. of Environment and Natural Resources
225 Green Street — Suite 714 / Systel Building
Fayetteville, NC 29301-5043
Dear b&. Rawls,
This letter is to inform you of additional land that has been acquired by lease to be used for vrawn
application for 30C #28, Attached is a copy of the Animal Waste Utilization AVwme*d. along wiI6 im
Animal Waste Utilization Plan Amendment.
If you have any questions or need additional information concerning this matter, please do not
hesitate to call me at [phone] ext. 238.
Sincerely,
Kevin West=
Environmental Caa*hwce
Manager
BROWN'S OF CAROLINA, INC,
785HWY24EAST P.O.BOX 487 - WARSAW. N.C. 28398 PHONE [phone]W

APR -12-2001 TIIO 08:38 AM BROWN' SOFCAROL I BA 9102966166 P. 04
A4P
ANIMAL WASTE UTILIZATION AGREEMENT
L J /3% n 's ° hereby give Brown's of Carolina,1= -
permission to apply animal waste from their Waste Utilization System, on
_ acres of my land for the duration of time shown below. The field (s)
on w ich waste can be applied are shown on the attached map. This agreement is
for 5 per acre.
I understand that this waste contains nitrogen, phosphorous, paumbon, and other
trace elements and when properly applied should not harm my land or crops. I
also understand that the use of waste will reduce my need for comanv_ W
fertilizer. t
Adjacent Landowner:
Waste Producer:
Date:
Date
Technical Representative- Date:
Term of Agreement: From TG n. / 2001 to 2=i
F3R6WN-S OF CAROLINA, INC.
765 H WY 24 FAST - N.O. BOX 487 - WARSAW, N,C. 2838tl - PHONF (910) 2W1W0
i ,r

Y APR -12-2001 THU 08:38 AIS
BROWN'SOFOAROLINA 9102966166
WASTE UTILIZATION PIAN
Amendment
s; for
OC #28
M,
The following acreage may be used for waste application based on the crop to be
grown and surface application:
P. 06
Tract
#
Field
#
Soil
Type
Crop
Lbs. N
Per Ac.
Acres
Lbs. N
Utilized
Month of
Application
11442
1.2.4.5
6,TO
ExA
Corn
145
75
10875
Marek -July
"
Wheat
144
75
10800
Sept-Apnl
"
soybeans
200
75
15000
June -Sept
11449
sA.TT
ExA
Corn
145
106
15370
Marries
"
Wheat
144
106
15265
-
"
soybeans
200
106
21200
June -Sept
Application of Waste by Irrigation
Field
#
Soil
Type
Crop
Application Application
Rate (In/Hr) Amount (In)
Any
Any
Any
.35 1
When applying waste on the above listed fields, the Required Specifications.snd
the Operation and Maintenance Procedures established by the original approved Waste
Utilization Plan will be followed and implemented. This amendment shall be attached to
the original Waste Utilization Plan and filed on-site at the farm and be available for
review by DEM upon request. A copy of the amended Waste Utilization Plan shall be
sent to the local Soil and Water Conservation District office.
Name of Facility Owner: Brown's of Carolina, Inc,
Signature; oC iu VJM I 4= Date: April 10, 2001
Name of Managerdf different from owner):
Signature: Date:
Name of Technical Specialist:_ _ M_ Kevin Weston
Affiliation: Bro se's Of Carolina Inc.
Address (Agency): P.O. Box 487
arsaw NC 28398
Signature: A . !/awo6m.. —Date: Aoril 10, 2001
i�71

T.� �y � �.� � �i � � ,`r�; `• •�t, �•' •,tip\'�\i �Z40
ra
�� ! .r{ .e• .rr y „ .��i r '1+` r.•j �~i 'v -4
1 �, - fy_- :- y ary •! IY;. ir.; -1 S `L
� �,yrr'.y�YI.{ i, c F: t i'., �., .,f• -1. itii,�,:-..- i' „1 • r 1i
� .e :f, • �I `A .`4- ' .� + � •, ,'p. y , 1.1 �' '. - ` _�\ t
JAW
co
co
co
CD
C7 '�..f�C;-;t'• ,.�: 4 �'�+•i' �'� � ,+�r:+;j' •�j''(�•; ;�,l.i'�?IL"� � 1 — =1 � I�
IP Re
CO
-Li -
t+L i ,'•.1' �-.. '.�ry'i�,...1..' r '' ��,� ••fit ' * j i-�1 r E
kj
:'. ti,;~. i•�,I i. 13 .. �,.�1`.�,�'r1'�.., • a41• r,'9=d1-, =� •b ` ,
SN
r ; d 1 rfl'.
can
IN IV
' �' 'C p 1 'er
•-� ' '�.i, 'L '/ y _ �yV- ` � i ',ram;, ' � - \+ + .
co
i ' n 1' /,>; •i ''l{tti,_�yl
co
CD
-'3 v fl jyL { '� 7A�ti iL e1
t
CV
Al P
Was
' _•y r ; .a .. : a .fir �. � � r V+ :. ; i .

BROW m "S
OF CAROLINA
April 10, 2001
Mr. Paul Rawls
Water Quality Regional Supervisor
N C Dept. of Environment and Natural Resources
225 Green Street— Suite 714 / Systel Building
Fayetteville, NC 28301-5043
Dear Mr. Rawls,
-- 1
APR 16 2001
This letter is to inform you of additional land that has been acquired by lease to be used for waste
application for BOC #28. Attached is a copy of the Animal Waste Utilization Agreement, along with an
Animal Waste Utilization Plan Amendment.
If you have any questions or need additional information concerning this matter, please do not
hesitate to call me at [phone] ext. 238.
Sincerely,
Kevin Weston
Environmental Compliance
Manager
BROWN'S OF CAROLINA, INC.
785 HWY 24 EAST • P.O. BOX 487 • WARSAW, N.C. 28398 • PHONE [phone]

T � _
BROvrN'S
OF-CAROLINA
-
rA.PR ° r 6 2nol
Rr
a.
ANIMAL WASTE UTILIZATION AGREEMENT
I, J r"rn�rr� /�%rn� j _ , hereby give Brown's of Carolina, Inc.
permission to apply animal waste from their Waste Utilization System, on
/M . acres of my land for the duration of time shown below. The field (s)
on which waste can be applied are shown on the attached map. This agreement is
for'?�-S per acre.
I understand that this waste contains nitrogen, phosphorous, potassium, and other
trace elements and when properly applied should not harm my land or crops. I
also understand that the use of waste will reduce my need for commercial
fertilizer.
Adjacent Landowner:
Waste Producer:
I- M-��
rI
Date: Y- 7 -U/
Technical Representative: .� +� _ Date: `j Lrl
Term of Agreement: From 7,, Q n , I , 2001 toLa,7 � , 2002
BROWN'S OF CAROLINA. INC.
785 HWY 24 EAST • P.Q. BOX 487 • WARSAW, N.C. 28398 • PHONE [phone]

r
WASTE UTILIZATION PLAN
Amendment
for
BOC #28
The following acreage may be used for waste application based on the crop to be
grown and surface application:
Tract
#
Field
#
Soil
Type
Crop
Lbs. N
Per Ac.
Acres
Lbs. N
Utilized
Month of
Application
11442
1,2,4.5,
6,10
ExA
Corn
145
75
10875
March -July
"
Wheat
144
75
10800
Sept -April
"
Soybeans
200
75
15000
June -Sept
11449
5-9,11
ExA
Corn
145
106
15370
March -July
"
"
"
Wheat
144
106
15265
Sept -April
"
Soybeans
200
106
21200
June -Sept
Application of Waste by Irrigation
Field
#
Soil
Type
Crop
Application
Rate (In/Hr)
Application
Amount (In)
Any
Any
Any
.35
1
When applying waste on the above listed fields, the Required Specifications and
the Operation and Maintenance Procedures established by the original approved Waste
Utilization Plan will be followed and implemented. This amendment shall be attached to
the original Waste Utilization Plan and filed on-site at the farm and be available for
review by DEM upon request. A copy of the amended Waste Utilization Plan shall be
sent to the local Soil and Water Conservation District office.
Name of Facility Owner:
Signature: oC
Name of Manager(If different from owner):
Signature: Date:
April 10, 2001
Name of Technical Specialist: M. Kevin Weston
Affiliation: Brown's Of Carolina, Inc.
Address (Agency): P.O. Box 487
Signature:
: April 10 2001

ro
IN
rw�' �.fl Ey�r ,t �� ,�' r� y J "�'• y . [ '� i' 1 N ,., r 't :i ti '�j.` \./
elf
� r i � �. s tK' ,�, �� �r.' r i 1 �{ ' r lrtg' �� , x ' \ 1 ! t"� � � •* �° I I � • ,
`�M,r � �','-0: • 'yI �� �� �,� S :. • }],' r,�' fir,,,(( '� t '�. ,'' � .�+•• `- M`'
-p:
e ti ..
a l ri •.
.. .Y• ,{'}i «. $#L�'l_F ,+,� r c ty r .C.'.M ,• + 1 .f t. lf�rj' ` IJ \ � ! '',. '4 � ! > •�. t
" '`:i , {�,,. :y n , F i r' Cb co
/�'-wt . ..,.yq ��f p�1'i'�f -Ik! `'si '.t'•r-�,� _.....'1..:'��''.'� 1y _-:�yr l�rl ; .t II CV
�; I 'i 1 ' ` 4 � r t �_t #. i� ` � � � '�''' , � �� '� } fit' �i 1 +- ��, • � +" r ' ' } } o
•]�• .ti }•! ;��'r �i" , Lr ,�' ,� wry` ��.t. \1 t, \ rY' � Y
3 . r. �' , ,h'• ,, " , : • t`,• k' 1 .,. 7 C'
7r,,jlr 9. 1:3 ..�i } ^�Ls,`r a.� �",i1.L ��%�; 3F' '���•���
�� �'i�
y y. T.•��4rr�.4.�r • ��,,i- 4 _, :5'' 'i 5;' � � � _'�}I�`ti � / 'i,}�}+h�'��3r�'�"SF r�r�� �-'•L � co
ti �''K"?:- �+. ;rt .•;`, ,t�,` " � : . ! 1.�k� A�'tt:- �•�.'�L � I ..!�'• i 'r' ��.[y: 1 �!E+,'�: `` , a � ,�r`'» • F
}�,}y ti .'�:- *: �L� A � k '' � �:; ...5';;,r 7 F,rrl i' '. � � �\ d Y•{ art
�. i>! i''' i's. i0 { � •?,�• � tS ,� `�-_A.. $ .q, �- t a' ',S�•��,�. ` `t Prl�,, l,yt'` .,�:•�;�• r!.
TL. %
r +c} Y . J," >; ; � { ��, � ' y • i P q S; 1' ., I � i��l rk \
All } r,

I :::
SEP -15-00 FRI 12:15 PH BROWN'S OF CAROLINA!
2 BROWNT
0 CAROLINA
t F C5
Fax
FAX NO, 2961333
765 Hwy 24 East
PO SM 487
Z..Wai�ft,NC 28396-0497
1871.6326
910-29"166 - Fax
To. Paul Rawls From Kevin Weston
r Vk
Fam 910-2.96-6166 Paso= 2 includinjI.Over-
Phone- 91 Q296-1600 oaten 9115/00
VrV
Re: CC..
v= N,1
0 Uffsent U For Review D Please Comment 11 Please Reply 0 Please Recycle
a comments.,
if you do not receive all of the pages please call Kendal
910-296-1l300 x 241
-.3V
W.
40.
P. 01/08

SEP -15-00 FRI 121-15 PH BROWN'S OF CAROLINA! FAX N0. 2961333 P. 02/08
F
S
SeptLaither 15, 2(+00
Re:giowil W ater Qu al Ity Supervisor
N.C. Dept, a -f Environnwiit and natural Resources
rayetieville Regiona101Yice r
225 (;rtcn St_ Suilc 71;1 Syslel Bldg.
Faycticville, NC 28301-5043
Dear Ali_ P--. iwIs,
Thi i lets r is in response to tic Notice of Violation And Recommendation for Enforcement letter
for Brown's of Carolim Fame # 28 dated August 21, 2000. ;
During clic routine inspection conducted on August 9, 2000 it was noted that the PAN bid been
ovor .;pplicd on severe] pulls in excess of tie CAWMP. Brawn's of Carolina rocognixcs that the over
rpplieations are non-compliant with die General Permit for tluis facility, however, Bpgm is of Carolina
rIL-lde. c%vey t'fforl to j%-uiige the excess water accumulated from die hurricanes of last fall and th. winter of
1999/2000 in Ilie rnost environ nicaully sound manner possible. This was accomplished by irrigating onto
Il Ic "Mglicni" and "driest" pulls of each field such that no nui-off or discha rge off. Because of the
esecss wr,te, frown the hurricanes and the extremely wet winter Lim followed; multwipplicatiwu to these
particiihir pulls w(,rc trade to lower and maituain lagoon levels to avoid non-compliaaoe. As a result, tlscso
Pulls reeeiveel large volumes of water Umt caused over appliealions of PAN. While the over applications of
PAN .arc non-compliant, this was the niost environrncntally sound way to manage the excess water and
pi•cve:r:t nLii-c.ff or discl�'trges.
To aid is (lac pre wsilion of over-applicalion in the future, wcckly irrigi ion schedules are
gcncrr.iW for cads application field These schedules prioritize the order in wlaeh tach pull is irrigated
Ilius ensut'ing a more teniform coverage throul Bout clic year.
Due to Iliz fact that Brown's of Carolina niawged and diligently recorded all of the excess water
►tithot I run-0lior discharges, irrigled in the inost euviroutnentally sound manner possible, and is
cc-mintrally improving the: ammagement practices of all its f icilitics, no enforcement action should be taken_
if yeu have any questions regarding dies mssponse, please do not hesitate to call me at
[phone] ext. 238.
Sincerely,,, ff
W
fv Kevin Weston
Environmental Compliance Manager
` rr
0[-OWN'S of CAROLINA. INC.
78:- I IWY 24 EAST - P.O. £OX 397 - WARSAW, N.C. 28308 - PHONE (910) 29G-1600

Reason for Visit (IRoutine O Complaint O Follow up O Emergency Notification O Other ❑ Denied Access
Facility Number
Date or Visit: T -1-� 'Time: i e� Printed un: 7/21/2000
(�
Q 7N,ot —operational Q Below Threshold
Permitted © Certified © Conditionally Certified (,] Registered Date Last Operated or Above Threshold: .........................
Farm Name: 6 0 G Z � County:......�,L Ci'�` .-.......
...................................................................................................................
Owner Name:
e ... ©..Aq ............. .............................................................................. Phone NP: ......... la..... 1..�........I............I....,..........
Facility Contact: ....1.7 ��h n t 5 Title:..14 ...�i.� ...r ................. Phone No: .................................. ..............
............................................... ....
Mailing Address: ..... V..-... '........ .(.............................................................. ....... r a r ../.. ..4�............. u'.. ?..
Qff
OnsiteRepresentative:........................................................................................................... integrator:................ ..........
..................... .................... ...
Certified Op era#vr:,..�Q..h.q......................C-CZA.y.\, ..................--......... Operator Certification Number:...............
Location of Farm:
❑ swine ❑ Poultry ❑ Cattle ❑ Horse Latitude �' �° Longitude
Design Current
Swine Canacitv Pvnulation
❑ Wean to Feeder
Feeder to Finish
Farrow to Wcan
❑ Farrow to Feeder
❑ Farrow to Finish
❑ Gilts
❑ Boars
Design Current Design Current
Poultry Capacity Population Cattle Capacity Population
❑ Layer �E] Dairy
❑ Non -Layer ❑ Non -Dairy
❑ Other
Total Design Capacity
Total SSLW
Number of Lagoons ❑ Subsurface Drains Present ❑ Lagan Area 10 Spray Field Area
Holding Ponds / Solid Traps JE1 No Liquid Waste Management System
Disebarttes & Stream Imuact5
I. is any discharge observed from any part of the operation? ❑ Yes PNo
Discharge originated at: ❑ Lagoon ❑ Spray Field ❑ Other
a. If discharge is observed, was the conveyance man-made?
El Yes pUNo
b. If discharge is observed. did it reach Water of the State`.' (If yes, notify DWQ) ❑Yes [No
c. If dischan-,e is uhscrved, what is the estimated flow in gal/tnin'?
d. Does discharge bypass a lagoon system? (If yes, notify DWQ) ❑ Yes No
2. Is there evidence of past discharge from any part of the operation? ❑ Yes JgNo
3. Were there any adverse impacts or potential adverse impacts to the Waters of the State other than from a discharge? ❑ Yes kT0
Waste Collection & TreatUnent
4. Is storage capacity (freeboard plus storm storage) less than adequate? ❑ Spillway ❑ Yes MNo
Struc:turc I Structure 2 Structure ± Structure 4 Structure i Structure 6
Identifier: ............................................... ....................................... .................................... ....................................
Freeboard (inches):
5100 Continued on back

r
Facility Number:Date of Inspection rT_7__dV_1 Printed on. 7/21/2000
5. Are there any immediate threats to the integrity of any of the structures observed? (ie/ trees, severe erosion, ❑ Yes ❑ No
seepage, etc.)
6. Are there structures on-site which are not properly addressed and/or managed through a waste management or
closure plan? Yes #No
(If any of questions 4-6 was answered yes, and the situation poses an
immediate public health or environmental threat, notify DWQ)
7. Do any of the structures need maintenance/improvement?
❑ Yes
gNo
8. Does any part of the waste management system other than waste structures require maintenance/improvement?
❑ Yes
V.No
9.Do any stuctures lack adequate, gauged markers with required maximum and minimum liquid level
a
. e r ab 9ra55 ',)-1 a� A eels 1—
P 0- wl c
elevation markings?
❑ Yes
99No
Waste Application
�Ste r I6�
.� .
10. Are there any buffers that need maintenance/improvement?
❑ Yes
f,vo
a Ponding KPAN ❑ Overload
11. Is there evidence of over application? ❑ Exce75m-,
Yes
El No
12. Crop type612r-14 146L C p
13. Do the receiving crops differ with those designat in the Certified Animal Waste dnauement P n (CA MP)?
❑ Yes
KNo
14. a) Does the facility lack adequate acreage for land application?
❑ Yes
No
b) Does the facility need a wettable acre determination?
❑ Yes
No
c) This facility is pended for a wettable acre determination'?
❑ Yes
VNo
15. Does the receiving crop need improvement?
❑ Yes
[No
16. Is there a lack of adequate waste application equipment?
❑ Yes
0No
Required Records & Documents
17. Fail to have Certificate of Coverage & General Permit readily available?
❑ Yes
KNo
18- Does the facility fail to have all components of the Certified Animal Waste Management Plan readily available?
(ie/ WUP, checklists, design, maps, etc.) ,
❑ Yes
9 N
19. Does record keeping need improvement? (ie/ irrigation, freeboard, waste analysis & soil sample reports)
❑ Yes
RNo
20. Is facility not in compliance with any applicable setback criteria in effect at the time of design?
❑ Yes
0N0
21. Did the facility fail to have a actively certified operator in charge?
❑ Yes
�o
22. Fail to notify regional DWQ of emergency situations as required by General Permit?
(ie/ discharge, freeboard problems, over application) E] Yes E] No
23. Did Reviewer/Inspector fail to discuss review/inspection with on-site representative'? ❑ Yes ENo
24. Does facility require a follow-up visit by same agency? ❑ Yes P bio
25. Were any additional problems noted which cause noncompliance of the Certified AWMP? ❑ Yes gNo
yiolatiQris :oi' def ci ma" -mere .h6 ed d. &. Jig {:his'Asit. - Yoit will •i-eeeive t'io fuirtMr - : - : -
:: cori-es orideizsce: abatil" this visit :::::::::::::::
Comments (refer to question #): Explain any YES answers and/or any recommendations or any other comments.
Use drawings of facility to better explain situations. (use additional pages as necessary):
�� 5P �c pI S �cu�+2 c)d'z7c� [' r6�5• L� a5 r►� �c 1 c� r� .�C� � c� {taS Stu e
Com
a
. e r ab 9ra55 ',)-1 a� A eels 1—
P 0- wl c
Uer p . n dere.
WA fo /bs � /6?4 - Z Z
lbs .4 /to e .310 4t /78-A,
�Ste r I6�
.� .
YID-eu / -zS'-�, ,,, � l - z ! 3 -l& -= - 5.7 � �/ � S,c - /Z. 711� -
Reviewer/Inspector Name .1 S
Reviewer/Inspector Signature:ZA41--Date: — / 5/00
V /

I
IVadlity Number: Date of Inspection
l
Odor Issues
26.
Does the discharge pipe from the confinement building to the storage pond or lagoon fail to discharge at/or below
AYes
❑ No
liquid level of lagoon or storage pond with no agitation?
27.
Are there any dead animals not disposed of properly within 24 hours?
❑ Yes
171 No
2$.
Is there any evidence of wind drift during land application? (i.e. residue on neighboring vegetation, asphalt,
❑ Yes
Mo
roads, building structure, and/or public property)
29.
Is the land application spray system intake not located near the liquid surface of the lagoon`?
❑ Yes
�No
30.
Were any major maintenance problems with the ventilation fans) noted? (i.e. broken fan belts, missing or
or broken fan blade(s), inoperable shutters, etc.)
❑ Yes
KNo
31.
Do the animals feed storage bins fail to have appropriate cover?
❑ Ycs
RNo
32.
Do the flush tanks lack a submerged fill pipe ora permanenthemporary cover?
s
❑ No
3/23/99

• FEB -27-2001 TIDE 12:44 F BROWN' SONAROLINA
BROWN'�
OF CAROLINA
FaX
9102966166
785 Hwy 24 East
PO Soot 487
Waftww, NG 2MG x487
etoa&law
14M-071
1110 -2"66 -Pax
C3 urgent a For MMOW ❑ Plume Comment ❑ Pim Reply a PKC Recycle
a February 27, 2001
Subject: Lagoon Levels llp.date
The following lagoons are within the 19" of freeboard as of February 26, 21301,
Farm # 28 18"
Farm # 29 18"
Gus Simmons 910-296-1$00 (Office)
Glenn Davis 910-296-1800 (Office) 910-290-0366 (Mobile)
Kevin Weston 910-29671800 (Office)

gnz
March 2, 2001
Mr. Paul Rawls
Water Quality Regional Supervisor
N C Dept. of Environment and Natural Resources
225 Green Street — Suite 714 / Systel Building
Fayetteville, NC 28301-5043
Dear Mr. Rawls,
RECEIVED
°5 2001
FKYrI-�" MVILLE
REG. OFFICE
This letter is in reference to a Fax that was sent to your office earlier this week concerning the
freeboard levels at BOC 428, Facility # 9-155 and BOC #29, Facility # 9-153 in Bladen County. This
letter will serve as a written report of the occurrence, as is required by the General Permit for these
facilities.
As stated in the Fax, the freeboard level at BOC #28 is 18" and BOC #29 is 18". This is due to
various factors and events that have occurred at these facilities that have allowed for limited pumping this
winter. As weather and field conditions improve, pumping %All resume and the lagoon levels will be
lowered. A Plan of Action for High Freeboard at Animal Facilities for each facility is enclosed. The
narrative sections of the plans give details of the contributing factors.
If you have any questions or need additional information concerning this matter, please do not
hesitate to call me at [phone] ext. 238.
Sincerely, `
Kevin Weston
Environmental Compliance
Manager
cc: Greg Brown
Gus Simmons
BROWN'S OF CAROLINA, INC.
785 HWY 24 EAST • P.O. BOX 487 • WARSAW, N.C. 28398 • PHONE [phone]

l q7
PLAN OF ACTION (PoA) FOR HIGH FREEBOARD AT ANIMAL FACILITIES
Facility Number: 9 - /S�� County: 131-4?>E"
t oe �zA-
Certified Operator Name: -16141.WY Cut .j Operator
# z3s7d
1. Current liquid level(s) in inches as measured from the current liquid level in the lagoon to the
lowest point on the top of the dam for lagoons without spillways; and from the current liquid level
in the lagoon to the bottom of the spillway for lagoons with spillways.
Structure 1 Structure 2 Structure 3 Structure 4 Structure 5 Structure fi
Lagoon Name/Identifier (ID): '. Z8
Spillway (Yes or No): H.
Level (inches): /F
2. Check all applicable items
Liquid level is within the designed structural freeboard elevations of one or more structures.
Five and 30 day Plans of Action are attached. Hydraulic and agronomic balances are within
• acceptable ranges.
Liquid level is within the 25 year 24 hour storm elevations for one or more structures. A 30 day
Plan of Action is attached. Agronomic balance is within acceptable range.
Waste is to be pumped and hauled to off site locations. Volume and PAN content of waste to
pumped and hauled is reflected in section III tables. Included within this plan is a list of the
proposed sites with related facility number(s), number acres and receiving crop information.
Contact and secure approval from the Division of Water Quality prior to transfer of waste
to a site not covered in the facility's certified animal waste management plan.
Operation will be partially or fully depopulated.
- attach a complete schedule with corresponding animal units and dates for depopulation
- if animals are to be moved to another permitted facility, provide facility number, lagoon
freeboard levels and herd population for the receiving facility
3. Earliest possible date to begin land application of waste: Tl,, lot _
1 hereby certify that I have reviewed the information listed above and included within the attached Plan
of Action, and to the best of my knowledge and ability, the information is accurate and correct
Or Allr-. Phone: 914 -eW -/Vev
Facility Owner/Manager (print)
/.SOC
Facility OwnerManager (signature)
PoA Cover Page 2121100
Date: 3 a

PLAN OF ACTION (PoA) FOR HIGH (FREEBOARD AT ANIMAL FACILITIES
30 DAY DRAW DOWN PERIOD
I. TOTAL PAN TO BE LAND APPLIED PER WASTE STRUCTURE
1. Structure Name/Identifier (ID): BOC #28
2. Current liquid volume in 25 yr./24 hr. storm storage & structural freeboard
a. current liquid level according to marker I 18.0 inches
b. designed 25 yr./24 hr. storm & structural freeboard 1 20.4 inches
c. line b - line a (inches in red zone) = 2.4 inches
d. top of dike surface area according to design
(area at below structural freeboard elevation) 320716 ft2
e. line c/12 x line d x 7.48 gallons/ft3 479791 gallons
3. Projected volume of waste liquid produced during draw down period
f. temporary storage period according to structural design 180 days
g. volume of waste produced according to structural design 422966 ft'
h. current herd # 4000 certified herd # 4000
actual waste produced = current herd # x line g =
certified herd #
i. volume of wash water according to structural design
j. excess rainfall over evaporation according to design
k. (lines h + i + j) x 7.48 x 30 days/line f=
4. Total PAN to be land applied during draw down period
I. current waste analysis dated 1 1117101
m. ((lines e + k)/1000) x line I =
REPEAT SECTION l FOR EACH WASTE STRUCTURE ON SITE.
(Click on the next Structure tab shown below)
PoA (30 Day) 2/21/00
422966 ft3
01 ft3
191333 ft3
765826 gallons
1.60 Ibs/1000 gal.
1993.0 lbs. PAN

II. TOTAL POUNDS OF PAN STORED WITHIN STRUCTURAL FREEBOARD ANWOR 25 YR.124
HR. STORM STORAGE ELEVATIONS IN ALL WASTE STRUCTURES FOR FACILITY
1.
Structure ID: BOC #28
line m =
1993.0 Ib PAN
2.
Structure ID:
line m =
Ib PAN
3.
Structure ID:
line m =
lb PAN
4.
Structure ID:
line m =
Ib PAN
5.
Structure ID:
line m =
lb PAN
6.
Structure ID:
line m =
ib PAN
n. lines +2+3+4+5+6= 1993.0 Ib PAN
III. TOTAL PAN BALANCE REMAINING FOR AVAILABLE CROPS DURING 30 DAY DRAW DOWN
PERIOD. DO NOT LIST FIELDS TO WHICH PAN CANNOT BE APPLIED DURING THIS 30 DAY PERIOD.
0. tract #
p. field # q. crop
r. acres
s. remaining ERR- t. TOTAL PAN u, application window'
2 PAN balance BALANCE FOR
(Iblacre) FIELD (Ibs.)
column r x s
4737
Zone 1 Small Grain Hay
1.24
43.84
54.2 Se t15-Oct;Feb-M
4737
Zone 2 Small Grain Hay
1.81
23.09
41.8 Se t15-Oct;Feb-M
4737
Zone 3 Small Grain Hay
2.08
24.45
50.9 Se t15-Oct;Feb-M
4737
Zone 4 Small Grain Hay
2.25
21.44
48.3 Sept 1 5 -Oct; Feb -M
4737
Zone 5 Small Grain Hay
3.29
34.28
112.9 Sept 1 5 -Oct; Feb -M
4737
Zone 8 Small Grain Hay
0.75
69.68
52.1 Sept 1 5 -Oct; Feb -M
4737
Zone 9 Small Grain Hay
0.75
51.91
38.8 Se t15-Oct;Feb-M
4737
Zone 10 Small Grain Hay
0.75
51.91
38.8 Sept 1 5 -Oct; Feb -M
4737
Zone 11 Small Grain Hay
0.75
36.22
27.1 Sept 1 5-Oct;Feb-M
4737
Zone 12 Small Grain Hay
0.75
51.91
38.8 Sept 1 5 -Oct; Feb -M
4737
Zone 13 Small Grain Hay
0.80
57.27
45.5 Sept 1 5 -Oct; Feb -M
4737
Zone 14 Small Grain Hay
0.80
60.70
48.3 Se t15-Oct;Feb-M
4737
Zone 19 Small Grain Grazed
6.01
22.20
133.4 Sept -Apr
4737
Zone 20 Small Grain Grazed
5.15
29.37
151.4 Sept -Apr
4737
Zone 21 Small Grain Grazed
5.07
20.13
102.1 Sept -Apr
4737
Zone 22 Small Grain Grazed
5.06
22.73
115.0 Sept -Apr
4737
Zone 23 Small Grain Grazed
4.92
24.95
122.8 Sept -Apr
4737
H d 16A Wheat
6.84
129.00
882.4 Sept -Apr
4737
Hyd 16B Wheat
3.59
129.00
463.1 Sept -Apr
4737
H d 17A Wheat
6.09
129.00
785.6 Sept -Apr
4737[---,
Hyd 176 Wheat
6.40
129.00
825.6 Sept -Apr
'State current crop ending application date or next crop application beginning date for available
receiving crops during 30 day draw down period.
v. Total PAN available for all fields (sum of column t) = 4178.6 Ib. PAN
IV. FACILITY'S PoA OVERALL PAN BALANCE
w. Total PAN to be land applied (line n from section II) = 1993.0 Ib. PAN
PoA (30 Day) 2121100

x. Crop's remaining PAN balance (line v from section III) = 4178.6 Ib. PAN
y. Overall PAN balance (w - x) _ -2186 Ib. PAN
Line y must show as a deficit. If line y does not show as a deficit, list course of action here including pump and
haul, depopulation, herd reduction, etc. For pump & haul and herd reduction options, recalculate new PAN
based on new information. If new fields are to be included as an option for lowering lagoon level, add these
fields to the PAN balance table and recalculate the overall PAN balance. If animal waste is to be hauled to
another permitted facility, provide information regarding the herd population and lagoon freeboard levels at the
receiving facility.
This farm is currently in a high freeboard status due to the fact that the irrigation system was recently converted
from traveler pulls to solid set. When the conversion was completed, the Waste Management Plan was
rewritten and a large part of the farms fields were changed from small grain grazed to small grain hay which
restricted the application windows. This change will be a help in the future, but was a hinderance at the present
time due to the windows. Because of the windows, this facility was limited on its choice of fields that could
receive effluent and was holding as long as possible to keep from applying outside of the windows. Once the
window opened at the first of February, pumping resumed however, the choice of fields has remained limited
due to weather and field conditions. As the conditions become favorable, pumping will continue and the lagoon
level will be lowered.
PoA (30 Day) 2121100

7 -
OCT -03-00 TUE 01:13 PH BROWN'S OF CAROLINA! FAX NO, 2961333,:.P. 01
Fal(
i
OWNCAROLINA'
-
3
! , .! e;A ;
Wirs'a"rir W 2n* -W7
MO-2WA4100
17600-M4MM
Fax
0
To Ole"
From:
Fay Pages:
phoneg Data
Rut CC:
EJ Urq*W; Cl For Review C1 Please Comment E3 Please
Recycle
Subject wl,
l
p
S -t, Lagoon Levels Update "p
The following lagoons are within the 19" of freeboard as of SepWMb64A�,20M.
Farm # 28 17'
Farm # 93A 18"
GUS SlImmons
Gann Davis
Kowin GVestnn
910-296-1800 (Office)
910-296-1800 (Office)
910-296-1800 (Office)
9 1 C Pasl iot 10 3;(Mobile)-
d T,
W

SEP -25-00 MON 04:43 PM BROWN'S OF CAROLINA! FAX NO. 2961333 P. 01
BROWNS
OF CAROLINA .
V�L
V. Page=
7W H" 24 East
1-800-871-6=
91 NARAI W — Fax
0
E3 urge" Q For Review Q Please Cernmwft 0 Ploase Reply " 13 , Please Recycle
1 41
Sepjem6er 20DO
Subje ct : Lagoon Levels Update
The following lagoons are no longer within the 19"
of freeboard as of September 23,
2000.
Farm# 13 13"
Farm# 28 14"
Farm # 29 14"— L45
Farm # 30 13*
Farm # 93A 167—
Gus Simmons 910-296-1800 (Office)
Glenn Davi:; 910-296-1800 (Office)
910-290-0366 (Mobile)
Kevin Weston 910-296-1800 (Office)

Murphy -Brown, LLC 5/24/02 2822 Hwy 24 West
P.O. Box 856
Warsaw, NC 28398
r�.
NUTRIENT UTILIZATION PLAN
Grower(s):
Farm Name:
Brown's of Carolina
BOC #28
County: Bladen
Farm Capacity:
Farrow to Wean 4000
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish
Storage Structure:
Storage Period:
Application Method:
Anaerobic Lagoon
X180 days
Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days priorto planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8
800119230123

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, W, tons, etc.):
Capacity Type Waste Produced per Animal Total
4000
Farrow to Wean
3212 gaVyr
12,848,000 gal/yr
19820.54
Farrow to Feeder
4015 galtyr
gal/yr
Farrow to Finish
10585 gaLtyr
gaVyr
Wean to Feeder
223 gaLtyr
gaVyr
Feeder to Finish
986 galtyr
gaVyr
Total 12,848,000 gaVyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs):
Capacity Type Nitrogen Produced r Animal Total
4000
Farrow to Wean
5.4 lbs/yr
21,600 lbs/yr
19820.54
Farrow to Feeder
6.5 lbs/yr
lbs/yr
Farrow to Finish
26 lbstyr
lbs/yr
Wean to Feeder
0.48 lbs/yr
Ibstyr
Feeder to Finish
2.3 lbs/yr
I
Total 21,600 lbs/yr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the, crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage:
Total N Required 1st Year:
Total N Required 2nd Year:
OWNED
LEASED
62.67
60.83
14817.70
19820.54
15833.04
19907.44
Average Annual Nitrogen Requirement of Crops: 15,325.37 19,863.97
Total Nitrogen Produced by Farm: 21,600.00
Nitrogen Balance for Crops: (13,589.34)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2 of 8
B00119230124

Reception Area Specifications
Year 1 of a 2 year rotation
Tract
Hydrant,
Zone
Irrigated
Acreage
Solt
Type
1 st Crop
Coda
Time to 1st Crop
Apply Yield
1st Crop Lbs N1Ac
lbs NlUntt Residual
Lbs N
/Ac
Total lbs N 2nd Crop
Utllfzed Cade
Time to
Apply
2nd Crop 2nd Crop Lbs N1Ac
Yield lbs NlUnit Residual
Lbs N
/Ac
Total lbs N
Utilized
Total
Lbs NlAc
Total Ips N
Utilized
4737
1
1.236
ExA
O
June -Sept
50
4.0
200
247.20
0
0.00
200
247.20
4737
2
1.812
ExA
O
June -Sept
50
4.0
200
362.40
"
0
0.00
200
382.40
4737
3
2.082
ExA
O
June -Set
50
4.0
200
416.40
"
0
0,00
200
416.40
4737
4
2.253
ExA
O
June -Sept
50
4.0
200
450.60
0
0.00
200
450.60
4737
5
3.294
ExAINa
O
June -Sept
47.5
4.0
190
625.86
'
0
0.00
190
625.86
4737
6
3.489
ExA1Na
O
June -Sept
47,5
4.0
190
662.91
0
0.00
190
662791
4737
7
2.019
ExA
O
June -Set
50
4,0
200
403.60
0
0.00
200
403.80
4737
5
0.747
ExA
O
June -Sept t
50
4.0
200
149.40
0
0.00
200
149.40
4737
9
0.747
Na
O
June -Set
45
4.0
180
134.46
0
0.00
180
134.46
4737
10
0.747
ExA
O
June -Sept t
50
4.0
200
149.40
0
0.00
200
149.40
4737
11
0.747
Na
O
JuneSe t
45
4.0
180
134,46
"
0
0,00
180
134,46
4737
12
0.747
ExA
O
June -Set
50
4.0
200
149.40
0
0.00
200
149.40
4737
13
0.795
Na
O
June -Sept t
45
4.0
160
143.10
0
0.00
180
143.10
4737
14
0795
ExA
O
June -Set
50
4.0
200
159.00
0
0.00
200
159.00
4737
15
3.097
ExA
O
June -Sept
50
4.0
200
619.40
0
0.00
200
619.40
4737
16
2.973
ExA
O
June -Sept
50
4,0
200
594,60
"
0
0.00
200
594.60
4737
17
5.289
ExA/A
O
June -Set
50
4.0
200
1057.80
0
0.00
200
1057.80
4737
18
3.585
ExA1A 8
O
June -Sept I
50
4,0
200
717.00
"
0
0.00
200
717.00
4737
19
5.009
ExA
D
Mar -July
130
1.3
15
147.5
886.33
N
Sept-Aiar
60
2.4
144
865.30
291.5
1751.62
4737
20
5.154
ExA
D
Mar Ju
130
1.3
15
147.5
760.22
N
Sept -Apr
60
2.4
144
742,18
291,5
1502,39
4737
21 i
5.07
ExA/A
D
Mar -July
130
1.3
15 1
147.5
747.83
N
Se t -A r
60
2,4
144
730.08
291.5
1477.91
4737
22
5.058
ExAJAyB
D
Mar-Juk
130
1.3
15
147.5
746.06
N
Se t -A r
60
2.4
144
728.35
291.5
1474,41
4737
23
4,92
ExA/A8
D
Mar -July
130
1.3
15
147.5
725.70
N
Sept -Apr
60
1 2.4
144
708,48
291.5
1434.18
Leased
Land
11442
24A
6.84
ExA
O
June -Sept
50
4.0
200
1368.00
0
a.00
200
1368,00
11442
248
3.59
ExA
O
June -Sept
50
4.0
200
71800
0
0.00
200
718.00
11442
25A
6.09
ExA
O
June -Sept
50
4.0
200
1216.00
0
0.00
200
1218.00
11442
2513
6.4
ExA
O
June -Sept 1
50
4.0
200
1280.00
0
0.00
200
1280.00
11442
26
4.92
ExA
O
June -Set
50
4.0
200
984,00
0
0.00
200
984.00
11442
27
13.05
ExA
O
June -Sept
50
4,0
200
2610,00
0
0.00
200
2610.00
11449
28
18.56
ExA
D
Mar -Ju
130
1,3
15
147.5
2737,60
N
Sept -Apr
60
2.4
144
2672.64
291.5
5410.24
11449
29
16.08
ExA
D
Mar -July
130
1.3
15
147.5
2371.80
N
Sept -Apr
60
2.4
144
2315.52
291.5
4687.32
11449
30
3.19
ExA
D
Mar -July
130
1.3
15
147,5
470.53
N
Sept -Apr
60
2.4
144
459.36
291.5
929.89
11449
31
2.11
ExA
D
Mar-Julv
130
1.3
15
147.5
311.23
N
Se t -A r
60
2.4
144
303.84
291.5
615.07
Totals.,
Leased
80.031
1
14069.13
1
1
1 1
3751.36
10820.51
Totals:
Owned
62.665
11043.3
3714.38
14817.70
3(a) orb B00119230125

Reception Area Specifications Year 2 of a 2 year rotation
Tract Field Irrigated Soil 1st Crop time to 1st Crop 1st Crop Lbs NlAC Lbs N Total Ibs N
Acreage Type Code Apply Yield Ibs NlUnit Residual IAc Utilized
2nd Crop Time to 2nd Crop 2nd Crop Lbs NIAc Lbs N Total tbs N
Code Apply Yield Ibs N1Unit Residual fAc Utilized
Total
Lbs NIAc
Total Ibs N
Utilized
4737
1
1.236
ExA
D
Mar-Juty
130
1.3
15
147.5
182.31
N
Sept -Apr
60
2.4
144
177.984
291.5
360,294
4737
2
1.812
ExA
D
Mar Jul
130
1.3
15
147,5
267.27
N
Se t-A r
60
2.4
144
260.928
291.5
528.198
4737
3
2.082
ExA
D
Mar-JWV
130
1.3
15
147,5
307.095
N
Sept -Apr
60
2.4
144
299.808
294.5
606.903
4737
4
2.253
ExA
D
MaT-Jury
130
1.3
15
147.5
332,3175
N
Se t-A r
60
2A
144
324.432
291.5
656.7495
4737
5
3.294
ExAfNa
D
Mar -July
127.5
1.3
15
144.375
475.5713
N
Sept -Apr
60
2.4
144
474.336
288.375
949.9073
4737
6
3.489
ExA/Na
D
Mar -July
127.5
1.3
15
144.375
503,7244
N
Se t-A r
50
2.4
144
502.416
2B8175
1006.14
4737
7 1
2.019
ExA
D
Mar-Ju
130
1,3
15
147.5
297.8025
N
Sept -Apr
60
2.4
144
290.736
291.5
588.5385
4737
8
0.747
ExA
D
Mar-Jutv
130
1,3
15
147.5
110.1825
N
Sept -Apr
60
2.4
144
107.568
291.5
217.7505
4737
9
0.747
Na
D
Mar-July,125
1.3
15
141.25
105.5138
N
Sept -Apr
60
2.4
144
107.568
285.25
213.0818
4737
10
0.747
ExA
D
Mar -Jul
130
1.3
15
147.5
110,1825
N
Sept -Apr
60
2.4
144
107.568
291.5
217.7505
4737
11
0,747
Ne
D
Mar -Jul
125
1.3
15
141,25
105,5138
N
Sept -Apr
60
2,4
144
107.568
285,25
213.0818
4737
12
0.747
ExA
D
Mar-Julv
130
1.3
15
147.5
110.1825
N
Sept -Apt
60
2.4
144
107.568 1
291.5
217.7505
4737
13
0.795
Na
D
Mar-Ju
125
1.3
15
141.25
112.2938
N
Se t-A r
60
2.4
144
114.48
285.25
226.7738
4737
14
0.795
ExA
D
Mar -Jul
130
1.3 m
mm15
147,5
117.2625
N
Se -A r 1
60
2.4
1
144
114.48
291.5
231.7425
4737
15
3.097
ExA
D
Mar-Ju
130
1.3
15
147,5
456.6075
N
Sept -Apr
60
2.4
144
445.968
291.5
902.7755
4737
16
2.973
ExA
D
Mat.luiy
130
1.3
15
147,5
436.5175
N
Sept -Apr
60
2.4
144
428.112
291.5
666.8295
4737
17
5.289
ExAIA B
D
Mar -Jul
130
1,3
15
147.5
780.1275
N
Sept -Apr
60
2.4
144
761,616
291.5
1541,744
4737
18
3.585
ExAJAVB
D
Mar-Juhl
130
1.3
15
147,5
528.7875
N
Sept -Apr
60
2.4
144
516.24
291.5
1045,028
4737
19
6.009
ExA
O
June -Set
50
4
200
1201,8
0
0
200
1201.8
4737
20
5.154
ExA
O
June -Sept
50
4
1 200
1030.8
0
0
200
1030.8
4737
21
5.07
ExA/A
O
June -Set
50
4
1
200
1014
0
0
200
1014
4737
22
5.058
ExAJAyB
O
June -Set
50
4
200
1011.6
0
0
200
1011.6
4737
23
4.92
ExA/A
O
June-5e t
50
4
200
984
0
0
200
984
Leased
Land
11442
24A
6.84
ExA
D
Mar-july
130
1,3
15
147,5
1006,9
N
Se t-A r
60
2.4
144
984.96
291.5
1993.86
11442
24B
3.59
ExA
D
Mar-JuY
130
1,3
15
147.5
529.525
N
Sept -Apr
60
2.4
144
516.96
291.5
1046.485
11442
25A
6.09
ExA
D
lyar-July
130
1.3
15
147.5
898.275
N
Se t-A r
60
2.4
144
876,96
291,5
1775.235
11442
258
6,4
ExA
D
Mar -July
130
1,3
15
14T5
944
N
Sept -Apr
60
2.4
144
921.E
291.5
1865.E
11442
26
4.92
ExA
D
Mar -July
130
1,3
15
147.5
725.7
N
Se t-A r
60
2.4
144
708.48
291.5
1434.18
11442
27
13.05
ExA
D
Mar -Jut
130
1.3
15
147,5
1 1924.875
N
Sept -Apr
60
1 2.4
144
1879.2
291.5
3804.075
11449
28
18,56
ExA
O
June -Sept
50
4.0
200
3712
•
0
0
200
3712
11449
29
16 08
ExA
O
June -Set
50
4,0
200
3216
0
0
200
3216
11449
30
3.19
ExA
O
June -Set
50
4.0
200
638
0
0
200
638
11449
31
2.11
ExA
O
June -Set
50
4.0
200
422
0
0
200
422
Totals: Leased
80.831
14019.28
1 5888.161
1 18907.44
Totals: Owned 62.6E 10 83.66 3240.376 15833.t>d
3(b) of 8 800119230126

i
CAWMP AMENDMENT
Brown's of Carolina Farm #28
5/7/02
This amendment is intended to incorporate the application of commercial fertilizer on corn into the
CAWMP for the above farm. In an effort to increase stand count and vigor, Brown's of Carolina applied
the equivalent of nine (9) pounds of plant available nitrogen (PAN) to the corn crop at planting. This
application should be noted on the IRR2 record keeping forms for all corn fields on this farm, and, in so
doing, be deducted from the PAN balance. The total PAN applied per field should not exceed the
allowance shown in the CAW IP.
A review of the CAWMP reveals that there is a substantial enough PAN deficit for this farm to
allow for this application of commercial fertilizer.
Pr^mn'e of f -�mU-n C k.—A,
Date
Date
S a
Date
800119230127

{ _ j This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized 1 unit yield
A
Barley
1.6 lbs N / bushel
B
Hybrid Bermudagrass - Grazed
50 lbs N 1 ton
C
Hybrid Bermudagrass - Hay
50 lbs N 1 ton
D
Corn - Grain
1.25 lbs N 1 bushel
E
Corn - Silage
12 lbs N 1 ton
F
Cotton
0.12 lbs N I lbs lint
G
Fescue - Grazed
50 lbs N /ton
H
Fescue- Hay
50 lbs N 1 ton
I
Oats
1.3 lbs N ! bushel
J
Rye
2.4 lbs N 1 bushel
K
Small Grain - Grazed
50 lbs N / acre
L
Small Grain - Hay
50 lbs N / acre
M
Grain Sorghum
2.5 lbs N 1 cwt
N
Wheat
2.4 lbs N 1 bushel
O
Soybean
4.0 lbs N 1 bushel
P
Pine Trees
40 lbs N I acre 1 yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4 of S 800119230128

SLUDGE APPLICATION:
I
t
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PAN/yr/animal Farm Total/yr
4000 Farrow to Wean 0.84 3360
Farrow to Feeder 1
Farrow to Finish 4.1
Wean to Feeder 0.072
Feeder to Finish 0.36
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 3360 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 16800 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 56 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 134.4 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
i -) APPLICATION OF WASTE BY IRRIGATION:
w 1
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
*This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for X180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist atter you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 8
B00119230129

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
24A
ExA
Soil
0.35
Application Rate
Application Amount
Tract
Hydrant
Type
Crop
in/hr
* inches
4737
1
ExA
O
0.35
1
4737
2
ExA
O
0.35
1
4737
3
ExA
O
0.35
1
4737
4
ExA
O
0.35
1
4737
5
ExA/Na
O
0.35
1
4737
6
ExA/Na
O
0.35
1
4737
7
ExA
O
0.35
1
4737
8
ExA
O
0.35
1
4737
9
Na
O
0.4
1
4737
10
ExA
O
0.35
1
4737
11
Na
O
0.4
1
4737
12
ExA
O
0.35
1
4737
13
Na
O
0.4
1
4737
14
ExA
O
0.35
1
4737
15
ExA
O
0.35
1
4737
16
ExA
O
0.35
1
4737
17
ExA/AyB
O
0.35
1
4737
18
ExA/AyB
O
0.35
1
4737
19
ExA
D
0.35
1
4737
20
ExA
D
0.35
1
4737
21
ExA/AyB
D
0.35
1
4737
22
ExA/AyB
D
0.35
1
4737
23
ExA/AyB
D
0.35
1
Leased Land
11442
24A
ExA
O
0.35
11442
24B
ExA
O
0.35
11442
25A
ExA
O
0.35
11442
25B
ExA
O
0.35
11442
26
ExA
O
0.35
11442
27
ExA
O
0.35
11449
28
ExA
D
0.35
11449
29
ExA
D
0.35
11449
30
ExA
D
0.35
11449
31
ExA
D
0.35
6 of 8 800119230130

' Additional Comments:
This elan revised to show wetted acres on the leased land. All acres shown
are wettable. The plan shows a two year rotation of com, wheat and soybeans.
This rotation is ossible only with the additional land that has been leased.
The total acres of each crop planted in any given year may vary from what is
shown, so long as the residual N from the soybeans is taken from the PAN
rate of the crop that follows the soybeans. (If wheat follows soybeans, subtract
the 15 lbs. N residual from the wheat rate.)
7 of 8 800119230131

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: BOC #28
Owner: Brown's of Carolina
Manager: David Nordin
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. l/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
} Name of Facility Owner:
Signature:
Brown's of Carolina
Name of Manager (if different from owner)
Signature:
Date
David Nordin
Name of Technical Specialist:
Affiliation:
Address:
Signature:
M. Kevin Weston
Murphy -Brown, LLC
2822 Hwy 24 West, PO Box 856
Warsaw, NC 28398
Telephone: [phone]
VQr--
Date
8 of 8 B00119230132

STATE OF NORTH CAROLINA
FARM LAND LEASE AND SPRAY
EASEMENT AGREEMENT
COUNTY OF BLADEN
James Otto Blanks, Jr. and wife, Daisy Swindell Blanks, and lank Wanks (Lessors) of 692
Blanks Dairy Rd., Clarkton, NC 28433 hereby lease to Brown's of Carolina, Inc. (Lessee) of 785 Hwy
24 Fast, PO Box 487, Warsaw, NC 28398, for a five year term commencing on January 1, 2002 and
running to December 31, 2007, all of that property, more particularly described in "Exhibit A7 attached
hereto and made a part themof
Said lease will commence on January 1, 2002, and end on December 31, 2007, with an option
to renew lease for an additional five years if agreeable to both parties. If either party does not choose
to renew lease a notice must be given in writing at least six months prior to end of original lease.
The terms and conditions of this Lease are as follows:
1. Lessee will pay to James Otto Blanks, Jr. sixty five (65) dollars per acre (180 acre)
$11,700.00 per year for all farming rights, including all rights of ingress, egress and regress.
This farm lease also includes a spray easement agreement on certain fields as shown on the
attached farm map. This will be paid during the first ten (10) days of January of each year
of the lease.
2. Lessee to receive the farm crop LDP payments and all other Government subsidies shall be
available to the Lessor.
3. Lessee will have the right to bury six (6) inch PVC pipe and install the appropriate
hydrants.
4. Lessor Hereby understands that this waste effluent contains nitrogen, phosphorus, potassium
and trace elements, and when properly applied should not harm any land or crops, and that
the use of animal manure effluent will reduce the need for commercial fertilizer.
5. Lessee will keep PH at least 5.5 or whatever yearly soil tests require and PH will be at least
5.5 at the end of the lease.
6. Lessee will keep ditch banks mowed and ditches cleaned out as needed to keep the farm
drained and neat in appearance. L: ssee will also keep roads in good condition and properly
maintained.
r'. Lessee agrees to provide up to forty (40) hours of bulldozer work on the leased fields, such
work to be done at a mutually agreed to time between the Lessor and Lessee.
B00119230133

8. Lessee is totally responsible legally and financially for any environmental liability caused
from the spraying of eluent during the leased period. -
} 9. - i his lease shall be for five (5) years with an option to renew at the end of the lease
.gpxement. At such time of renewal the annual rental payment will be adjusted in
accordance with changes in the Consumer Price index.
10. If at anytime, during the (5) year lease, the odor becomes offensive and a problem for the
Lessor and/or the lessor's neighbors, and can not be resolved by efforts of the lessee, then
this (5) year lease may be terminated with a 12 month notice.
11. LLessee will provide to Lessor one (1) B -B -Q pig each year of the lease by request of the
Lessor in writing.
12. Lessor will be responsible for all local and State due on property.
13. Lessor will have full utilisation of all buildings on the farm and be responsible for any
insurance coverage and repairs needed to such building.
14. Lessor reserves two(2) acres of cropland each year for the planting of tobacco.
anie Blanks
Lessee:
Brown's of Carolina, Inc.
By: Secretary
B00119230134

STATE OF NORTH CAROLINA
COUNTY OF ;
a Notary Public for said County and State, do hereby certify that
personally appeared before me this day and acknowledged the due
execution of the foregoing instrument.
Witness my hand and official seal, this the day of�2001-
My commission expires Z"A _raj - O& �.
NATE OF NORTH CAROLINA
�OUNTY OF 'S\cq
' o. Lr a Notary Public for said County and State, do hereby certify that
personally appeared before me this day and acknowledged the due
xeoof the foregoing instrument
Aitwss my hand and official seal, this the � day of�_,_2401.
Notary Public
y commission expires Q - rJ - 0a
'ATE OF NORTH CAROLINA
?UNTY OF
�` ;�, �iC•-. a Notary Public for said County and State, do hereby certify that
— personally appeared before me this day and acknowledged the due
cution of the foregoing instrumni.
Hess my hand and official seal, this the day of 1_Cj__,2001.
�Public���� BQp119230135

Mix rphy Brown
Kenan5ville Division Running Lagoon Level & Rainfall Report
Farm Name: 3728
Date Lagoon Level Rainfall(inches)
3/2/2002
28
0
3/9/2002
25
3
3/16/2002
25
1.2
3/23/2002
26
0.6
3/30/2002
27
0.4
4/6/2002
27
0
4/13/2002
28
0.1
4/20/2002
28
0
4/27/2002
28
0.2
5/4/2002
29
0
5/11/2002
28
1
5/18/2002
30
0.4
5/25/2002
31
0.6
6/1/2002
31
1
6/8/2002
33
0.4
6/15/2002
32
1.75
6/22/2002
37
0
6/29/2002
35
1.75
7/6/2002
37
0
7/13/2002
38
1
7/20/2002
39
0.5
7/27/2002
40
0.6
8/3/2002
41
2.5
8/10/2002
44
0
8/17/2002
47
0
8/24/2002
47
0.7
8/31/2002
44
4.25
9/7/2002
44
0
9/14/2002
46
1
9/21/2002
44
1.5
9/28/2002
46
0.2
10/5/2002
47
0
10/12/2002
47
0.4
10/19/2002
45
2
10/26/2002
44
0.2
11/2/2002
43
0.9
11/9/2002
42
0.9
11/16/2002
40
1.25
11/23/2002
38
1.25
11/30/2002
36
0
12/7/2002
36
0.6
12/14/2002
35
1.35
12/21/2002
35
0.6
12/28/2002
34
0.6
1/4/2003
32
1
1/11/2003
32
0
1/18/2003
32
0.2
1/25/2003
32
0.17
2/1/2003
31
0.52
2/8/2003
30
0.9
2/15/2003
29
0.7
2/22/2003
28
1.1
Wednesday, April 30, 2003 page I

o`'C� W AT§I r Q
co
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E. Director
Division of Water Quality
December 1, 2006
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Brown's of Carolina LLC
Farm #128 (BOC)
PO Box 487
Warsaw, NC 28398
Subject: Application for Renewal of Coverage for Expiring NPDES General Permit
Dear Permittee:
Your facility is currently approved for,operation under one of the Animal Waste Operation NPDES General Permits, which expire on
July 1, 2007. Due to changes in federal rules, facilities that do not discharge nor propose to discharge may choose whether or not to
retain coverage under an NPDES General Permit. Copies of the draft animal waste operation NPDES general permits and the State
Non -Discharge General Permits are available at http://h2o.enr.state.nc_usl4ps/afou/downloads.htm or by writing or calling:
NCDENR — DWQ Animal Feeding Operations Unit
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure y ur continued coverage under one of these two types of general permits, you must submit an application for permit
coverage to the Division. Enclosed you will find a `Request for Certificate of Coverage Facility Currently Covered by an Expiring
NPDES General Permit:' The application form must be completed and returned by January 2, 2007. Please note you must include
two (2) copies of your most recent Waste Utilization Plan with the application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil penalty.
Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-215.1 and could
result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the draft general permits, the enclosed application, or any related matter please feel free to contact the
Animal Feeding Operations Unit staff at 919-733-3221.
Sincerely,
Ted L. Bush, Jr., Chief
Aquifer Protection Section
Enclosures
cc (w/o enclosures): Bladen County Soil and Water Conservation District
Fayetteville Regional Office, Aquifer Protection Section
AFO Unit Central Files - 090155
Brown's of Carolina LLC
Aquifer Protection Section 1636 Mail Service Center Raleigh. NC 27699-1636
lnternet: www.ncwaterquality org Location: 2728 Capital Boulevard Raleigh, NC 27604
An Equal OpportunitylAiSnnaWe Action Employer— 50% Recycledl10°% Post Consumer Paper
Telephone:
Fax 1:
Fax 2:
Customer Service:
N�pr�rtCarolina
(919) Naturally
[phone]
[phone]
[phone]

BOC Farm
Sprayfields
Scale: I"=500'
1 1�
6 4 3 1
5
7 Lagoon
1`r
Hog Houses
800119230136
Hydrant #
Acres
1
1,236
2
1,812
3
2.082
4
2.253
5
3.294
6
3.489
7
2.019
8
0.747
9
0.747
10
0.747
11
0.747
12
0.747
13
0.795
14
0.795
15
3.097
16
2.973
17
5.289
18
3.585
19
6.009
20
5.154
21
5.07
22
5.058
23
4.92
Total
62.665
w/100' offsets
Ip

BOC Farm
Sprayfields
Scale: 1"=1000'
Hydrant #
Acres
1
1.236
2
1.812
3
2.082
4
2.253
5
3.294
6
3.489
7
2.019
8
0.747
9
0.747
10
0.747
11
0.747
12
0.747
13
0.795
14
0.795
15
3.097
16
2.973
17
5.289
18
3.585
19
6.009
20
5.154
21
5.07
22
5.058
23
4.92
24A
6.84
24B
3.59
25A
6.09
25B
6.4
26
4.92
27
13.05
28
18.56
29
16.08
30
3.19
31
2.11
Total
143.495
Mi
'EVI/V
� a
o
v z
002919 `
Of -5 i G NES
��NIN��' B00119230137

.ti
BOC Farm X28
S i l d
iydront
Acres
p r a yf e s
24A
6.84
(Blanks Land)
24B
25B
3.59
6.09
258
6.4
26
4.92
Scale: 1"=500' 500'
27
28
13.05
18.56
29
16.08
30
3.19
31
2.11
Total
80.83
800119230138

Murahv_Rrnwrt_ 11 C �1 ✓ 413120Q9 2822 Hwy 24 West
Grower(s):
Farm Name:
P.O. Box 856
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN ��GFI�ED
Murphy -Brown, LLC
3728 {Old BOC #28}
county: eiaaen
Farm Ca aci :
Farrow to Wean 4000
Farrow to Feeder
Farrow to Finish
Wean to Feeder
Feeder to Finish
Storage Structure:
Storage Period:
Application Method:
Anaerobic Lagoon
>180 days
Irrigation
WM-F 1G*w.*I�'
RECEIVED / DENR 1 DWQ
Aquifer Protection Section
APR 0 6 2009
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen
Either of these conditions may result in runoff to surface waters which is not allowed
under DWO regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1of11

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft', tons, etc.):
Capacity Type Waste Produced per Animal Total
4000
Farrow to Wean
3212 gal/yr
12,$48,000 gal/yr
Farrow to Feeder
4015 gal/yr
gal/yr
Farrow to Finish
10585 gaVyr
gal/yr
Wean to Feeder
223 gal/yr
gal/yr
Feeder to Finish
986 gal/yr
gallyr
Total 12,848,000 gal/yr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs):
Capacity Type Nitrogen Produced per Animal Total
4000
Farrow to Wean
5.4lbs/yr
21,600 lbs/yr
Farrow to Feeder
6.5 lbs/yr
lbs/yr
Farrow to Finish
26 lbs/yr
lbs/yr
Wean to Feeder
0.48 lbs/yr
lbs/yr
Feeder to Finish
2.3 lbs/yr
lbs/yr
Total 21,600 lbs/yr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
OWNED LEASED
Total Irrigated Acreage: 62.67 83.96
Total N Required 1st Year: 14817.70 20443.77
Total N Required 2nd Year: 15833.04 20822.58
Average Annual Nitrogen Requirement of Crops: 15,325.37 20,633.17
Total Nitrogen Produced by Farm: 21,600.00
Nitrogen Balance for Crops: (14,358.54)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2 of 11

Reception Area Specifications
Year 1 of a 2 year rotation
Tract
Hydrant,
Zone
Irrigated
Acrea e
Soil
TvPe
1st Crop
Code
Time to
Appiv
1st Crop
Yield
1st Crop
lbs N1Unit
Lbs NIAc
Residual
Lbs N
[Ac
Total lbs N
Utilized
2nd Crop
Code
Time to
Apply
2nd Crop
Yield
2nd Crop Lbs NIAc
lbs NlUnit Residual
Lbs N
/Ac
Total lbs N
Utilized
Total
Lbs NIAe
Total lbs N
Utllfzed
4737
1
1.236
ExA
0
June -Set
50
4.0
200
247.20
0
0.00
200
247.20
4737
2
1.812
ExA
0
June -Sat
50
4.0
200
362.40
0
0.00
200
362.40
4737
3
2.082
ExA
O
June -Set
50
4.0
200
416.40
0
0.00
200
416.40
4737
4
2.253
ExA
O
June -Set
50
4,0
200
450.60
'
0
0.00
200
450.60
4737
5
3.294
ExA/Na
O
June -Set
47.5
4.0
190
625.86
0
0.00
190
625.86
4737
6
3.489
ExA/Na
O
June -Set
47.5
4.0
190
662.91
0
0.00
190
662.91
4737
7
2.019
ExA
0
June -Set
50
4.0
200
403.80
'
0
0.00
200
403.80
4737
8
0.747
ExA
0
June -Set
50
4.0
200
149.40
0
0.00
200
149.40
4737
9
0.747
Na
0
June -Set
45
4.0
180
134.46
0
0.00
180
134.46
4737
10
0.747
ExA
0
June -Set
50
4.0
200
149.40
0
0.00
200
149.40
4737
11
0.747
Na
0
June -Set
45
4.0
180
134.46
0
0.00
180
13476--
4737
12
0.747
ExA
O
June -Set
50
4.0
200
149.40
'
0
0100
200
149.40
4737
13
0.795
Na
0
June -Set
45
4.0
180
143.10
0
0.00
180
143.10
4737
14
0.795
ExA
0
June -Set
50
4.0
200
159.00
0
0.00
200
159.00
4737
15
3.097
ExA
O
June -Sept
50
4.0
200
619.40
0
0.00
200
619.40
4737
16
2.973
ExA
0
June -Set
50
4.0
200
594.60
0
0.00
200
594.60
4737
17
5.289
ExA/Ay.B. ExA/A
0
June -Set
50
4.0
200
1057.80
0
0.00
200
1057.80
4737
18
3.585
r=xA/AYB
O
June -Set
50
4.0
200
717.00
0
0.00
200
717.00
4737
19
6.009
ExA
D
Feb15-June
130
1.3
15
147.5
866.33
N
Sept -Apr
60
2.4
144
865,30 1
291.5
1751.62
4737
20
5.154
ExA
D
Feb15-June
130
1.3
15
147.5
760.22
N
Sept -Apr
60
2.4 1
144
742.18
291.5
1502.39
4737
21
5.07
ExAIA B
D
Feb15 June
130
1.3
15
147.5
747,83
N
Se -
60
2.4
144
730.08
291.5
1477.91
4737
22
5.058
ExA/A
D
Feb15-June
130
1.3
15
147.5
746.06
N
Sept -Apr
60
2.4
144
728.35
291.5
1474,41
4737
23
4.92
ExAlAyB
D
Feb15-June
130
1.3
15
147.5
725.70
N
Sept -Apr
60
1 2.4
144
708.48
291.5
1434.18
Leased
Land
11442
24A
6.84
ExA
O
June -Set
50
4.0
200
1368.00
0
0.00
200
1368.00
11442 1
24B
3.59
ExA
O
June -Set
50
4.0
200
718.00
"
0
0.00
200
1 718.00
11442
25A
6.09
ExA
0
June -Set
50
4.0
200
1218.00
0
0.00
200
1218.00
11442
258
6.4
ExA
O
June -Set
50
4.0
1
200
1280.00
0
0.00
200
1280,00
11442
26
4.92
ExA
O
June -Set
50
4.0
200
984.00
0
0.00
200
984.00
11442
27
16.21
ExA
0
June -Set
50
4.0
200
3242.00
"
0
0.00
200
3242.00
11449
28
18.56
ExA
0
Feb15-June
130
1.3
15
147.5
2737.60
N
Sept -Apr
60
2.4
144
2672.64
291.5
5410.24
11449
29
1 16.05
ExA
D
Febl5-Juno
130
1.3
15
147.5
2367.38
N
Se -
60
2.4
144
2311.20
291.5
4678.58
11449
30
3.19
ExA
D
Febl5-June
130
1.3
15
147.5
470.53
N
-Sept-Apr
60
2.4
144
459.36
291.5
929.89
11449
31
2.11
ExA
D
Feb15-June
130
1.3
15
147.5
311.23
N
SOPt-8K
60
2.4
144
303.84
1 291.5
615.07
Totals:
Lensed
83,961
1 14896.73
1
5747,041
1 20443.77
Totals:
Owned
62.665
11043.31
3(a) of 11

Reception Area Specifications Year 2 of a 2 year rotation
Tract Field Irrigated Soil 1st Crop Time to 1st Crap 1st Crop Lbs N1Ac Lbs N Total Ibs N
Acrea a Type Code Apply Yield Ibs WWII Residual !Ac Utilized
2nd Crop Time to 2nd Crop 2nd Crop Lbs N1Ac Lbs N Total Ibs N
Code Apply Yield Ibs NlUnit Residual fAc Utilized
Total
Lbs NlAc
Total Ibs N
Utilized
4737
1
1.236
ExA
D
Fe615-June
130
1.3
15
147.5
182.31
N
Sept -Apr
60
2.4
144
177.984
291.5
360.294
4737
2
1.812
ExA
D
Feb15-June
130
1.3
15
147.5
267.27
N
Sept -Apr
60
2.4
144
260.928
291.5
528.198
4737
3
2.082
ExA
D
Feb15-June
130
1.3
15
147.5
307.095
N
$ept-Apr
60
2.4
144
299.808
291.5
606.903
4737
4
2.253
ExA
D
Feb15-June
130
1.3
15
147.5
332,3175
N
Sept -Apr
60
2.4
144
324.432
291.5
656.7495
4737
5
3.294
ExA/Na
D
F015-June
127.5
1.3
15
144.375
475.5713
N
Sept -Apr
60
2.4
144
474,336
28B.375
949.9073
4737
6
3.489
ExA/Na
D
Feb15•June
127.5
1.3
15
144,375
503,7244
N
Seot-Avr
60
2.4
144
502.416
288.375
1006.14
4737
7
2.019
ExA
D
Feb15-June
130
1.3
15
147.5
297,8025
N
Se t-Apr
80
2.4
144
290.736
291.5
588.5385
4737
8
0.747
ExA
D
Feb15-June
130
1.3
15
147.5
110.1825
N
Sept -Apr-
60
2A
144
107.56E
291.5
217.7505
4737
9
0.747
Na
D
Feb15-June
125
1.3
15
141.25
105.5138
N
Sept -Apr
60
2.4
144
107.568
285.25
213.0818
4737
10
0.747
ExA
D
Febl5-June
130
1.3
15
147.5
110,1825
N
Sept -Apr
60
2.4
144
107.568
291.5
217.7505
4737
11
0.747
Na
D
Feb15-June
125
1.3
15
141.25
105.5138
N
Sept -Apr
60
2.4
144
107.568
285,25
213.0818
4737
12
0,747
ExA
D
Febl5-June
130
1.3
15
147.5
110,1825
N
Se t- r
60
2.4
144
107,568
291.5
217,7505
4737
13
0.795 1
Na
D
Feb15-June
125
1.3
15
141.25
112.2938
N
Sept-Avr
60
2.4
144
114.48
285.25
226.7738
4737
14
0.795
ExA
D
Feb15-June
130
1.3
15
147.5
117,2625
N
Sevt-Avr I
60
2.4
144
114.48
291.5
231,7425
4737
15
3.097
ExA
D
Feb15-June
130 1
1.3 1
15 1
147.5
456.8075
N
Sept -Apr
60
2.4
144
445.968
291.5
902.7755
4737
16
2.973
ExA
D
Feb15-June
130
1 1.3
15
147.5
438.5175
N
Sept -_ Sept -_Apr
60
2.4
144
428.112
291.5
866,6295
4737
17
5.289
ExA/A B
D
Feb15-June
130
1.3
15
147.5
780,1275
N
Sept -Apr
60
2.4
144
761.616
291.5
1 1541.744
4737
18
3.585
ExA/A
D
Feb15-June
130
1.3
15
147.5
528.7875
N
Sept -Apr
60
2.4
144
516.24
291,5
1045.028
4737
19
6.009
ExA
O
June -Set
50
4
200
1201.8
0
0
200
1201.8
4737
20
5.154
ExA
O
June-S t
50
4
200
1030.8
0
0
200
1030.8
4737
21
5.07
ExA/A B
O
June -Set
50
4
200
1014
0
0
200
1014
4737
22
5.058
ExA/A B
O
1 June -Sept
50
4
1 200
1011.6
0
0
200
1011.6
4737
23
4.92
ExAIA B
O
June -Set
50
4
200
984
0
0
200
984
Leased I
Land
11442
24A
6.94
ExA
D
Feb15-June
130
1.3
15
147.5
1008.9
N
Sept -Apr
60
2.4
144
984.96
291.5
1993.86
11442
24B
3.59
ExA
D
Fob15-June
130
1.3
15
147.5
529.525
N
Sept -Apr
60
2.4
1"
516.96
291.5
1046,485
11442
25A
6.09
ExA
D
Feb15-June
130
1.3
15
147.5
698.275
N
Sept -Apr
60
2.4
144
876.96
291.5
1775.235
11442
25B
6.4
ExA
D
Feb15-June
130
13
15
147.5
944
N
Sept -Apr
60
2.4
144
921.6
291.5
1865.6
11442
26
4.92
ExA
0
Feb15-June
130
1,3
15
147.5
725.7
N
Sept -Apr
60
2.4
144
708.48
291.5
1434.18
11442
27
16.21
ExA
D
Feb15-June
130
1.3
15
147.5
2390,975
N
r
60
2.4
144
2334,24
291.5
4725.215
11449
28
18.56
ExA
O
June -Set
50
4.0
200
1 3712
1
0
0
200
3712
11449
29
16.05
ExA
O
June -Sept
50
4.0
200
1 3210
0
0
200
3210
11449
30
3.19
ExA
O
1 June -Set
50
4.0
200
638
'
0
0
200
638
11449
31
2.11
ExA
O
June-S t
50
4.0
200
422
0
0
200
422
7orals: Leased
83.96
14479.38
OU3.201
20822.58
Totals: Owned 97993
3(b) of 11

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code Crop
A Barley
B Hybrid Bermudagrass - Grazed
C Hybrid Bermudagrass - Hay
D Corn - Grain
E Corn - Silage
F Cotton
G Fescue- Grazed
H Fescue - Hay
I Oats
J Rye
K Small Grain - Grazed
L Small Grain - Hay
M Grain Sorghum
N Wheat
O Soybean
P Pine Trees
Lbs N utilized / unit yield
1.6 lbs N 1 bushel
50 lbs N 1 ton
50 lbs N 1 ton
1.25 lbs N I bushel
12 lbs N l ton
0,12 lbs N 1 lbs lint
50 lbs N / ton
50 lbs N I ton
1.3 lbs N 1 bushel
2.4 lbs N 1 bushel
50 lbs N 1 acre
50 lbs N 1 acre
2.5 lbs N / cwt
2.4 lbs N / bushel
4.0 lbs N / bushel
40 lbs N 1 acre 1 yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4 of 11

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farre Specifications PAN/yr/animal Farm Totaltyr
4000 Farrow to Wean 0.84 3360
Farrow to Feeder 1
Farrow to Finish 4.1
Wean to Feeder 0.072
Feeder to Finish 0.36
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 3360 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 16800 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayfand at the
rate of 300 pounds of nitrogen per acre, you will need 56 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 134.4 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
'This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for X180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rales to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5of11

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Leased Land
11442
24A
Soil
O
Application Rate
Application Amount
Tract
Hydrant
Type
Crop
in/hr
inches
4737
1
ExA
O
0.35
1
4737
2
ExA
O
0.35
1
4737
3
ExA
O
0.35
1
4737
4
ExA
O
0.35
1
4737
5
ExA/Na
O
0.35
1
4737
6
ExA/Na
O
0.35
1
4737
7
ExA
O
0.35
1
4737
8
ExA
O
0.35
1
4737
9
Na
O
0.4
1
4737
10
ExA
O
0.35
1
4737
11
Na
O
0.4
1
4737
12
ExA
O
0.35
1
4737
13
Na
O
0.4
1
4737
14
ExA
O
0.35
1
4737
15
ExA
O
0.35
1
4737
16
ExA
O
0.35
1
4737
17
ExAIAyB
O
0.35
1
4737
18
ExA/AyB
O
0.35
1
4737
19
ExA
D
0.35
1
4737
20
ExA
D
0.35
1
4737
21
ExA/AyB
D
0.35
1
4737
22
ExA/AyB
D
0.35
1
4737
23
ExA/AyB
D
0.35
1
Leased Land
11442
24A
ExA
O
0.35 1
11442
24B
ExA
O
0.35 1
11442
25A
ExA
O
0.35 1
11442
25B
ExA
O
0.35 1
11442
26
ExA
O
0.35 1
11442
27
ExA
O
0.35 1
11449
28
ExA
D
0.35 1
11449
29
ExA
D
0.35 1
11449
30
ExA
D
0.35 1
11449
31
ExA
D
0.35 1
6 of 11

Additional Comments:
This plan revised to show the corrected acreage for the pivot at 27 & 29.
The plan shows a two year rotation of corn, wheat and soybeans.
This rotation is possible only with the additional land that has been leased.
The total acres of each crop planted in any given year may vary from what is
shown, so long as the residual N from the soybeans is taken from the PAN
rate of the crop that follows the soybeans. (If wheat follows soybeans, subtract
the 15 lbs. N residual from the wheat rate.)
7 of 11

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: 3728 (Old BOC #28)
Owner: Murphy -Brown, LLC
Manager:
Owner/Manager Agreement:
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
pian for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
Itwe understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: -Murphy-Brown, LLC
Signature:
Name of Manager (if different from owner):
Signature:
Name of Technical Specialist: M. Kevin Weston
Affiliation: Murphy -Brown, LLC
Signature:
Address: 2_822 Hwy 24 West, PO Box 856
Warsaw, NC 28398
Telephone: [phone] -_
8of11
Date
Date
Date

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recievinq crop type, or available land.
Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips) -
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies -
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
9 of 11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist'. Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
10 of 11

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
Duman consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.

State of North Carolina RECE !f F)
Department o€ Environment, Health and Natural Resources
Division of Water Quality MAY 1 4 1991
Non -Discharge Permit Application Form I Survey
(THIS FORM MAY BE PHOTOCOPIED FOR USE AS AN ORIGINAL) REG. FAY�i�i.EV��11_,
OFFICE
General Permit - Liquid Animal Waste Operations
The following questions have been completed utilizing information on file with the
Division. Please review the information for completeness and make any corrections
which are appropriate. If a question has not been completed by the Division, please
complete as best as possible. Do not leave any question unanswered.
Application Date:
4-,R8-9-7
I. REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
Applicants
1. One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
2. Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is disposed;
3. Two copies of the Certified Animal Waste Management Plan (CAWMP). If the facility does
not have a CAWMP, one must be completed prior to submittal of a general permit application
for animal waste operations.
II. GENERAL INFORMATION:
1. Farm's name: Farm #28
2. Print Land Owner s name: Brown's of Carolina Inc
3. Land Owner's Mailing address: EQ Box 487
City: W Saw N -C Zip:
Telephone Dumber: 919 4 9=9AQZt q l0 — A 9 �0 = 11 n b_._. , —
4. County where farm is located:. Bl en
5. Farm Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a copy
of a county road map with the location of the farm identifigd): �&W� 211 C-AsT- vF G-A9Lp1�___—
6. Print Farm Manager's name (if different from Land Owner):
7. Lessee's 1 Integrator's name (if applicable; please circle which type is listed): Brown'5 of Car lingC_.
FORM: AWO-G-E 2126/97 Page 1 of 3

III. OPERATION INFORMATION:
I. Farm No.: Q2-155
2. Operation Description: oWration
Farrow to Wean
4000 - Certified Design Capacity
Is the above information correct? W yes; 0 no_ If no, correct below using the design capacity of the facility
T} fie of Swine No. of Animals Type of Poultry No. of Animals Z= of Cattle No. of Animals
0 Wean to Feeder 0 Layer 0 Dairy
0 Feeder to Finish 0 Non -Layer 0 Beef
0 Farrow to Wean (# sow) 0 Tuckey
0 Farrow to Feeder (# sow)
0 Farrow to Finish (# sow)
Other Type of Livestock on the farur: No. of Animals
3. Acreage cleared and available for application. ; Required Acreage (as listed in the CAWMP): 194z5-4- {03.1
4. Number of Lagoons: 1 ; Total Capacity: A/ao i f 4$ Cubic Feet (0)
Number of Storage Ponds: 0 ;Total Capacity: Cubic Feet (ft3)
5. Is animal waste being applied on any field which has subsurface drains? YES or O (please circle one)
6. Are subsurface drains present in the vicinity of or under the lagoon? YES or O (please circle one)
IV. APPLICANT'S CERTIFICATION:
I, &a'S P1 F C �U _�aC (Land Owner's name listed in question 11.2), attest that
this application for (Farm name listed in question 11.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be rep4neto me as incomplete.
Slgnature� W12k ^ Date 'Z�' 9 7
Q.A 2 or- 0A1UL; �A! f .
V. M GER'S CERTIFICATION: (complete only if different from the Land Owner)
I, (Manager's name listed in question 11.6), attest that this
application for (Farm name listed in question IL I )
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all requited parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be returned as incomplete.
Signature
Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
PERMITS AND ENGINEERING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FORM: AWO-G-E 2/26/97 Page 2 of 3

State of North Carolina
Department of Environment, Health and Natural Resources
Division of Water Quality
Non -Discharge Permit Application Form / Survey
(THIS FORM MAY BE PHOTOCOPIED FOR USE AS AN ORIGINAL)
General Permit - Liquid Animal Waste Operations
DIVISION OF WATER QUALITY REGIONAL OFFICES (2197)
Asheville Regional WQ Supervisor
59 Woodfm Place
Asheville, NC 28801
[phone]
Fax[phone]
Avery
Macon
Buncombe
Madison
Burke
McDowell
Caldwell
Mitchell
Cherokee
Polk
Clay
Rutherford
Graham
Swain
Haywood
Transylvania
Henderson
Yancey
Jackson
Duplin
Fayetteville Regional WQ Supervisor
Wachovia Building, Suite 714
Fayetteville, NC 28301
[phone]
Fax [phone]
Washington Regional WQ Supervisor
943 Washington Square Mall
Washington, NC 27889
[phone]
Fax[phone]
Beaufort Jones
Bettie
Lenoir
Camden
Martin
Chowan
Pamlico
Craven
Pasquotank
Currituck
Perquimans
Dace
Pitt
Gates
Tyrell
Grwne
Washington
Hertford
Wayne
Hyde
Duplin
Mooresville Regional WQ Supervisor
919 Nortb Main Street
Mooresville, NC 28115
[phone]
Fax [phone]
Raleigh Regional WQ Supervisor
3800 Barrett Dr.
Raleigh, NC 27609
[phone]
Fax [phone]
Chatham
Nash
Durham
Northampton
Edgecombe
Orange
Franklin
Person
Granville
Vance
Halifax
Wake
Johnston
Warren
Lee
Wilson
Wilmington Regional WQ Supervisor
127 Cardinal Drive Extension
Wilmington, NC 28405-3845
[phone]
Fax[phone]
Anson
Moore
Alexander
Lincoln
Brunswick New Hanover
Bladen
Richmond
Cabamrs
Mecklenburg
Carteret Onslow
Cumberland
Robeson
Catawba
Rowan
Columbus Pender
Harnett
Sampson
Cleveland
Stanly
Duplin
Hoke
Scotland
Gaston
Union
Montgomery
hedell
Winston-Salem Regional WQ Supervisor
585 Waughtown Street
Winston-Salem, NC 27107
[phone]
Fax [phone]
Alamance
Rockingham
Alleghany
Randolph
Ashe
Stokes
Caswell
Surry
Davidson
Watauga
Davie
Wilkes
Forsyth
Yadkin
Guilford
FORAI: AWO-G-E 2197 Page 3 of 3

�OFROWN9s
CAROLINA.
BROWN'S OF CAROLINA FARM #28
4000 FARROW TO WEAN
STATE ROAD #211 - BLADEN COUNTY
DIRECTIONS: FROM CLARKTON, TAKE HIGHWAY #211 SOUTH TOWARD
BOLTON. FARM WILL BE ON LEFT APPROXIMATELY 3 MILES FROM CLARKTON,
MAILING ADDRESS:' SHIPPING
BROWNFS OF CAROLINA - FARM 128 BOC #28
P.O. BOX 487 STATE ROUTE 1211
WARSAW, NC 28398 CLARKTON, NC 28433
WORK: [phone]
BROWN'S OF CAROLINA, INC
303 EAST COLLEGE STREET • PO. BOX 487 • VVARSAW. N C 78398-0487 • OFFICE: [phone] • FAX, [phone]
r
Im
r
1l Lm Lit
-
}
- un
—
um
•
Lm ?.?
tm�
4> + u
IMP
� r 5
u
.. Ito iza
tm im
4
V-9
t�
�'r
_-vim
f
_
+ra
.+a rei
>V
MIL
L!J
ter. a
•
DIRECTIONS: FROM CLARKTON, TAKE HIGHWAY #211 SOUTH TOWARD
BOLTON. FARM WILL BE ON LEFT APPROXIMATELY 3 MILES FROM CLARKTON,
MAILING ADDRESS:' SHIPPING
BROWNFS OF CAROLINA - FARM 128 BOC #28
P.O. BOX 487 STATE ROUTE 1211
WARSAW, NC 28398 CLARKTON, NC 28433
WORK: [phone]
BROWN'S OF CAROLINA, INC
303 EAST COLLEGE STREET • PO. BOX 487 • VVARSAW. N C 78398-0487 • OFFICE: [phone] • FAX, [phone]

AP:T'R�..AL, WitY'£'3 2 X%MGZ!MT PL.Lq CSrZ=ICATIOH FOR NSW OR =PA2M= F==TS
Please rat71=— the a platad foss to the Divisioa of at
the add ---San = the reverse side of this fo }} ,/
Name of f (Please pr' ) : C�c�n%� � L.��(1!x r 0
Address: CrK-
Phone No.:
ra_= location: Latitude and Longitude:,''/{recuired) - Also,
Please attach a c!mpy of a county road map with locatde.*tttified.
'Lyre of operation (swine, layer. dairy, etc.
Design capacity (number of ani= ls) : d -w — ?cK n1
Average size of eperat_cn (1.2 month population: avg.)
Average ac,eage needed for lard application of waste (acres): /49"Y C'
--_=ana�caaaaaaavana=a�aaaaaaasaaasaaaaaa:aaaa�amaa:=aaataa�aaaaaaaaaaay=»aass3
TQG'-�-' cal Spee; a? ist Car—ti_icatiaa _
As a technical srecia.;St designated by the North Carolina Soil and Water
Conservation Commission pursuant to ISA NCAC 6r .0005, I certify that the new or
expanded animal waste management system as installed for the fa ---M named above
has a -i animal waste management plan that meets the design, construction,
operation and =aintenance standards and specifications oz the Division of
Environmental Management and the USDA. -Soil Conservation Service and/or the North
Cardlizia Soil 'and Water Conservation. Commission pursuant to 15A NCAC 2H.0217 and
ISA NCAC 6F .0001.-.0005. The following e" ements and their corresponding minimum
criteri_-ha bee: verified by me or other designated tec?Lnical specialists and
are included in the plan as applicable: minimum sepazations (buffers); liners or
equivalent for lagoons or waste storage ponds; waste storage capacity; adequate
quantity and amcs.:_^_t of land for waste utilization. (or use of third party) ; access
or omens:.ip of proper waste application equipment; schedule for timing of
applications; application rates; loading rates; and the control of the discharge
of pollutants from stouter r-,noff events less severe than the 25 -year, 24-hour
storms.
2va=a of Tech=ICA1, speclal,a st lease Print):
Ai i 11 _ 2p i /l S
Phone No. /U ���i�3^ 3c9d�
Sig:iatur
Date:
;Nth
i {we) eraticn a_^_d maintenance procedures established in the
aporoved animal waste management plan For the farm named above and will implement
these procedures. I (we) know that any additional expansion to the existing
design camacity of the waste treatment and storage system or construction of new
facilities will regz:ize a new certification to be submitted to the Division of
Environmental Management before the new animals are stocked. I (we) also
understand that there must be no discharge of animal waste from this system to
sur=ace waters of the state either through a man-made conveyance or through
unoff from a storm event less severe than the 25 -year, 24 -hoes= storm. The
approved plan will be filed at the fare and at the office of the local Soil and
Water Conservation District.
Na=e of Taz:d Ogrser ((Pl-eJas P_�nt) ��?� ��'•�• 5 c` ,�2� L ir1'a -��C
Signature: Date:
Name of Hagar, ?f differer_t frcm owner (Please print):
Signature: Date :
Xv p: A charge in lard cwnership requires notification or a new certification
(if the approved plan is changed) to be submitted to the Division of
Env:ror,me.^_tal Mar_age-me:-,t wit:zin 60 days of a title transfer.
DP -4 USE ONLY:ACYcw#

NUTRIENT MANAGEMENT PLAN
Growers):
Farm Name:
County:
Farm Type:
Farm Capacity:
Storage Structure:
Storage Period:
Application Method:
Brown's of Carolina
Farm 28
Bladen
Far -Wean
4000
Anaerobic Lagoon
180 days
Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
Z. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
Page: i

5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft3, tons, etc.):
4000 animals X 3212 gailanimal/year =
12848000 gallons
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs):
4000 animals X 5.40 lbs/animal/year =
21600 lbs
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
Page: 2

The following acreage will be needed for waste application based on the crop to be grown,
soil type, and surface application.
Tract
Field
Soil
Type
Crop
Code
Yield
/Ac
lbs N
/unit
Acres
Lbs N/Ac
Residual
Lbs N
/Ac
lbs N
Re uired
Time to
Apply
4737
10
ExA
C
6.5
50.00
t
2.2325.0
715.00
Mar -Oct
4737
8
AyB
C
6.3
50.00
9.0 315.0
2835.00
Mar -Oct
4737
9
ExA
C
6.5
50.00
2.5 325.0
812.50
Mar -Oct
4737
6
ExA
C
6.5
50.00
3.3 325.0
1072.50
Mar -Oct
4737
4
ExA
C
6.5
50.00
3.4 9 325.0
1105.00
Mar -Oct
4737
7
ExA
C
6.5
50.00
3.3 ; 325.0
I
1056.25
Mar -Oct
4737
un15
ExA
C
6.5
50.00
13.0 325.0
4225.00
Mar -Oct
4737
un12
ExA
C
6.5
50.00
25.0 ' 325.0
8125.00
Mar -Oct
4737
11
ExA
C
6.5
50.00
2.0__.-, 325.0
650.00
Mar -Oct
4737
-10
ExA
K
50.00
2.2 50.0
110.00
S -April
4737
-8
AyB
K
50.00
9.0 50.0
450.00
S -April
4737
--9
ExA
K
50.00
2.5 50.0
125.00
S -April
4737
,-6
ExA
K
50.00
3.3 50.0
165.00
S -April
4737
--4
ExA
K
50.00
3.4 50.0
! 170.00
S -April
4737
-•7
ExA
K
50.00
3.3 50.0
� 162.50
S -April
4737
-un15
ExA
K
50.00
13.0 50.0
650.00
S -April
4737
--un12
ExA
K
50.00
25.0 50.0
1 1250.00
S -April
4737
-r11
ExA
K
50.00
2.0 50.0
i
100.00
S -April
Total 63.7.
23778.75
Available N
21600.00
*Difference
-2178.75
--Indicates that this field is being overseeded (i.e. interplanted) or winter annuals follow summer
annuals.
*A negative number reflects the total lbs of additional nitrogen needed to achieve yields on
acreage listed in chart. A positive number means additional acreage is required to utilize the
nitrogen produced by the farm.
NOTE:
This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
I
Page: 3

The applicator is cautioned that N and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
The following legend explains the crop codes listed in the table above:
Crop Code Crop
A Barley
B Hybrid Bermudagrass - Grazed
C Hybrid Bermudagrass - Hay
D Com - Grain
E Corn - Silage
F Cotton
G Fescue- Grazed
H
Fescue- Hay
I
Oats
J
Rye
K
Small Grain - Grazed
L
Small Grain - Hay
M
Grain Sorghum
N
Wheat
O
Soybean
Lbs N utilized 1 unit yield
1.6 lbs N / bushel
50 lbs N / ton
50 lbs N / ton
1.25 lbs N / bushel
12 lbs N 1 ton
0.12 lbs N / lbs lint
50 lbs N / ton
50 lbs N / ton
1.3 lbs N / bushel
2.4 lbs N / bushel
100 lbs N 1 acre
133 lbs N 1 acre
2.5 lbs N l cwt
2.4 lbs N / bushel
4.0 lbs N / bushel
Page: 4

Acres shown in the preceding taole are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 0.84 pounds of plant available nitrogen per animal per year in the
in sludge based on the application method listed earlier.
If you remove the sludge every 5 years, you will have approximately 16800.00
pounds of PAN to utilize. Assuming you apply this PAN to hybrid bermudagrass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 58.00 acres of land. If you apply
the sludge to corn at a rate of 125 pounds per acre, you will need 134.40 acres of land.
PIease be aware that these are only estimates of the PAN and land needed. Actual requirements
could vary by 25% depending on your sludge waste analysis. soil types, realistic yields, and
applications.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
The following is provided as a guide for establishing application rates and amounts.
Page: 5

Tract
Field
Soil
Type
Crop
Application Rate Application Amount
in/hr *inches
4737
10
ExA
C, K
0.35 1.50
4737
8
AyB
C, K
0.35 1.20
4737
9
ExA
C, K
0.35 1.50
4737
6
ExA
C, K
0.35 f 1.50
4737
4
ExA
C, K
0.35 1.50
4737
7
ExA
C, K
0.35 i 1.50
4737
un15
ExA
C,K
0.35 ; 1.50
4737
un12
ExA
C,K
0.35 1.50
4737
11
ExA
C, K
0.35 1.50
*This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months_ In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsiability of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
Additional Comments:
Page: 6

NUTRIENT MANAGEMENT PLAN CERTIFICATION
Name of Farm:
Owner/Manager Agreement:
Brown's of Carolina, Farm 28
Itwe understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
Ywe understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Brown's of Carolina, Inc.
Signature:
j� Date
Name of Manager (if different from owner): G [ e K- K 4✓GZ (� L S
Please Print
Signature:
Date
Name of Technical Specialist:
Affiliation:
Address:
Signature:
Telephone:
Jimmy R. Vinson
Brown's of Carolina, Inc.
P.O. Box 487
Warsaw, NC 28398
[phone]
-/ - 4 -4("a
Date
Page: 8

., r`� ��« • ., ,tit � �,e '••���� � i h � iLt �'. �!� ��1� 1{ ram, L �. -, _ _. �`.�€a xr s �'- � . .
'-�1= .� � � , '� ` z.r 4- �,i: �x��� F� 4 ��. I �t r 1 . � _ r I .— _ � J. _ l„-- •-« .. �, �.... ...w. ~"` M1 f"
.'�� ... K. { ,= s Y ✓i�;. A �s �I,�r •�yM `r- c�" ��' _Q r • -r i,-,—
{t!Isi, • °` . .y K F,r, ti. i �' S+ 'hRil 'i.S� '+. ,� ` +l . � . Q 1 1 y a . - . ul . i
�' �. � r' ? cur ^ �r� w'r.,. � . �_,:,.• c-{
y�� � 3n ' r. y�n�fa p .• � ii�'•r 1.,e„ . �1 f 'i •�:. Sr, '.,• ....., _. .• + ... '.... _,_ � .� _.. � .� ..- . �.. � _ � ��
#� (� � �r <;�Z, .F - 1'�; .•`L [�"''�'�`'"'``ti "h��" SCE r't 4'
14
`� r '4` - tk'4 .•a .. . is , '4 ;r llr'x'!^-"'Tt'c* 7ow
'i! r5 f4
1� � r 1 � ! y ~'r• S. r l,l F �•xsi- �-i•�;. rfi t�,J � , sa t -r -' .� :}�,1, s r
r<r
,• r ,; , � � '��, s WO,
1>0 .D � '"+Are � �. � '+" . x�r, }rr•�,
i 3 s ! ►• r?j - TJ ' ; y ?i �A r'.' - �. �.�
� • �' t >S: .'AT.71 '.: ' {.Y u�(�T�,} tq , I �i `� ,:r!*,�� °! � � - '' 1- '4 t 1 y •l e fy f•: iFp�adp �d�
- ,. , •�^4r• F4�` i'1 !-. �.1 w' ��' � '�h�r { ' ^ 'y ` ,� rtYi j:i -`�" . � -L• ' is r �'• y�4y�y'L r
> • �; ,� 4::i .� :i�' �y{ce'i' r • ,qr i sJsRO.
sr ,. , � � � -£�'y �`J�` i► a +'�}. �?' 1 ..�\ .��; ►i'5�,�) :�: Kd r,� +�'�
wo
yy.�� 'Ti 4'r^pf4��ny t � t ��• -�5y ' +- SJr mot• - � �f.� '�,+yy � ... - ?
t"•,° t Ir'L(s '�.•' ir�s�..� •5 '1 �• 1 �'�F i�' {f;' �>i� "1r-� ;t,. .+�. '^��il'•'t r„•.: 'S�4 �t�'r�4-rh ,-. "LYy 1..� �Z, `}' qs �h'a�R°f.'��r!' �'�,�`
s,,��# � :' �•r +i' .r,. r... �, M1L�„.t,'. ` �i"'t `Y' �`•..Cr i :+k +p FF 1'�. ,,y�.r.i% ,�`,i�ry. ���.,`.�i-r fti = :•'Rf r.{..�'f ..�.,�Ynt" lr} �'.� j jy�• 'CR
rtrr�v \ � �:l. dr � L'1 nSr � ' f , �� '+Fr..�'" yt 4 � `J � �; 14 rr „`1'`'�r1';1,�1 �.�1•�'f%' :s,p;+��.•� Tb�,1! I
. '/h•, t �' r" s� i `` y7 en .,4;' r r 3 ` fit'b:hr T�'7j' �+t}1J�y1
�hr ��i/ • 'r', �T r it � i t S ! f t Rx" i. ;ix�i' i �iyn � � fr ,�' ' � `°1 } 1� h .}y, Ie�•, .r? tk rt 'J �r rA`pi �t.. � �� "[y -i
1l a �.l�.,d. ..r,' 1 .n � •{il. „!. '• i e.:ir ••� �N a ��, .:,p�•, �� ,f ( r•.' Tr�°.tj;F�IC.~•�, rIV' ��' S�#�,;�'•�.!�,?.%,r�
,� ,� �? � ! t ,i ;✓ 14 • � �' { I �+'ry � ���{�jt � a 5{ , t -1�.� �.�'` f-�'- d'ti' FSti'' fr t � "�•'I ri'. � r • 7i ":.
5 •f' •,� � t 1 r1 W +' .'�r7ir� . L•t7-`"��/� ��• � `y� S'r' C' �hWt,,'t~�• Lfr +•'k
�,.� � � 1�i V � ! �'W r. t y• 1�. ri jl ifPt"�!� ♦ + ��.f ��L�y,+.G'� Sn�f +%tile �to�'. ry.ii +!r; •''%�/5 ,,�' SiKS�V����4'r� ���:: k•:«1M �'
.'�', �• r��,• ' � ,y` f. _ � Sew+' + ti • °i d ! �L .f �, ahk' " j'¢.I� �"1'r !�� i4L4 �+j'� 5 W�a`�'*• `: 1' .1` r ��.iS,(,�1, �1 `•%f l+=,, ,� � i wjG�'�!r
y ♦ rj` �♦j r. i'�7t � $<,`� ,w+ } t���}q,�'�'" � .l r' S/ y,Jit ..:�r��(qq{'�,eday�, rrr c"Lb:,l.:a' ��q� S I r. Ll 1.3y��g7�(r`�RY �j'4i N.,��"i �airil'
�f 1�'�l,w i#1'-•rji'•.1. �F �,',T�;�i,. ° ` ` �,�r'c lfe,. l,�t���.��'{; 'i.,, Ali'xi",�.=1�+r��'Vil.7�':T..-1'r- `+�5t�y '�V s� r. 'f�'�'t' �'!, �"i''1'l''^r:"
( J. (_ � ` T i s ' ly er.-;� !':�.r L• •.�S ' �[ fl '�' � ' r • � F,. 1r'Yrr� � � f ` ••�j+ J, �•`% � ��i•�.
ri'�•.t+��'.,,2�a�
f", Ori f i}`y f• t •° - 'k "J� 11 ,9 "t'► 'fir 441r r. a• i r44i-
'Y- t �7 .:� �� y' r 1 �•f 1 s • Q•:: !.{ n .i r k� '�'�, � i`r o',�; •�•i! !- 49 ,o-fir
,, r. .�y r~ �r? ��� reyw rx � ,•>~ • • w i r • '�j'+':r ) , � s
' {'L L' Jai j'7' r.�'I' i Y' �1 !� i !M •.• . yrj .r .3 r"r' t �} �31 w q�'r, ?
a. °�fY} _ 4:'F� „tr,ry • ),;,� 5 . i rt r+d- - �' ' r G'r •C. L" � � ,. i1J r ,rri+%(r'�r�, ' � 11 .1fry,
7 s % i
•��r ✓;./'! t �t`.J",i � r�) J a •..` `�i' �(y514� 'j Nr f t '0 • rr�"'r ,F $,1� '�' ��rt'F►.+�`^t11 1 'i `y'r' -�. trti�'1�' r•�r1� �• X y�. �..e '•e" Y Y,51
"'`'ti. fr •rr. x� ,,`,gyp �-1,�•T.rl���tp ��ir t'` 't' f1� t`,• .i rF��•�,�{- r�i i��l^ �r+� 'Th, •r tjs!�F{,.�'`r• �� ti � er _! 'r "L`tyy, i,l�t� ,-R' k�i= )
,�rhY;.4'�w•*•'r'"<l�it r ': '{M1°' .� �•'rr'�,Yry.`�•-4•`St'i7 7'/',�{j, ''� '�r,. Ir Siti,ll ;•1:�r-1;.1• yl! i) i7#. +rr�'" ry; 4 r,_' t 5� ri''- ���'''S �d�'
�+:, +.s i _• si. -' x r • Q {.` " rh aM
J Ts�� + l.�v ty�;; f' f {f &! J �' •1 yr,� S' �Y' O f, r
♦ t�,.ftT;r,;i+r�A/^i (yi�.t`rti '�,tY�,.-.r, a•.I'F� 'L.� 1 ••1�5{` •t; iF�Fi+�'.t.4.+�.'♦yr,,:,,t�a!'�iStfr IC�j1[F1i }.�L} -''''r .fi .. 'F'tiyyr• i r � � v,.'* � ra )K �! � o�; ,•,. „'+�• yr
01
;,,�" 't";+`�rls,_,.fA„rti��.jr,�Y,- tr' ..•.'.*»r�� _ '91..l)-..� Al�,�r _ �.yy�'}''^/.r :���r� "�; \,`. •_•�: r i.F:j��u� • •r,���tnFr�'�-��'��•'f`'.wi �L: ��}`r�
r7..h...i' Qi `•4+• �' t-� • i� , r, y f, _..,. _ . �; -
a ar` ;�.LI : i �L " '•�%1 1..� a• .'l.r'+. r t?': \ ! ,r^• +�r y r " r ti.. ++�� r
,'i•,fi»y.r *�rt. "Ih.f'.f' ,I.7.. , t r1 Ji'�. T''-.j �I+i-S•%14',•. [ }WON
„� a/'{. Y t,.- '.!_.f.' i - `♦
..X -l'. 'Y.:U'' f • Y' .t _T•' r - •i ,•/�; 1.�` j'C�l� \ \ '.r•` �. ! ?�.-', �dddddd S� 4{'F t t
�.. '. r1�Y';.5.+pf*.. �1''la��"� * .:� €y �J _ .. '� �' �f � i ,r. ♦ j ; "."�,;.=. j, 1'l r �� rr,`h" iY6-�y�� tf L/t }+�r.�� ry;l�' �7 �fSF f: , /�
r��.�+4.• '*'Fr'f�•"�,Y/.(.:: , f r .��!� i1 ',t4 i�i 7 ��y^'r.�w ' s , LrY��rF'i �t ;a:,. � r. � Y 1t, 'i'lj� '. �,�7 �~�.1� t- ��ti �!� i r.. � ,•Y„rti i , < r: ♦` `
.r Sy.S?°r ki •.1 1p. Si.l 4 j �' 7+ 7 1`�t 'F i•r;i�( .I; 1' �S, LFt1tf
K1 CA)Li lr i
rL_ �� � r l } ,• •[1 ''•, ;,.� r.'i frG .�. - �y.iFT ''• i r,l ! G �A -� I'. +.
r,f�'i:54,•i �1' a4r✓'. �,I:�'�t +'',�' r ?�i.+=5 ,, {'1 r- r �,��;,e'Y •.-.f.' fi.• iF S _r `, j,'';p•.r ;{I'_- Y'Y1T;,tt+„,4�„�j' <,i •r;-!
i�r>x••�✓5/� 1'.1�1 °,'+�+-r �'( pi 'l+'��t' �'r'j°!(i��•"; ,, � tF>-rFi] �{t::r .`��'�. 'S� 'i, :°r..•:-:�- ;,'i ( �-'1Ai„ ., Z{:�-' ��i'•'.
a+,s ai s�`�,�:;ir�r-'� 1,v CS4+�i.�ii•�: 3. r,;..„. �•1,._I•`�, r '. , ',r� :i• .�>•c; I ,,. r � •�,.c
r.t. �n•".•�ffT J .±L•Yf .�r�. �' . ! -;i f. ,1 M=: i- • ., / r ��r1 jG at;i.-.;: 4✓�r
i. •1'�..'" y. +� F �.•+ �``= c •��Y +r'ti •ri`i-t�l lot .,.•"' ` ..
Jt�y�/.��'SfJ'+y.ir�•SyeT/`� r!•.r.S.a �1'rr�P�r .;t.;: +�.H.P.( �•7fy� 1�A / Zoo
_^L'i-`:'h•. �.rr�� �, ;�.` i /ryr",r fiy.i, lf� .. d ^..rl. :r ,r „''_1i a• :rt ! ��'!�;-i'�: �:F 7� !! .., �..
1, ••'''�"7 y� lid ;r '�1}N/•yl k. dr.-1, , �(+�r1 t y;4,� 1,.I
t'. y'b' ,,• R - i' , , .f 4�. f; - J -i;fir.' m �"J ✓ +.'w 7�• r ; k ' L�.' �' �' �,. ', '�t
�!'yrl. f.,�"•;';,�nr�r;;�`i�•�' R''r.�� F,', �;t„���1 •�� I,i l . I h t, �'.'�j;�l Y ak.L'tiSl;.�i� i•.%'j ..�Jr�� � 'raa �'••d �r.
,� yy j`!rl k. �-....s �l* +1r�Yi�}S .��` � %' / „ ''i i ' r; `. � i j_.L r � r:�.. r: �" ;�-�.!I})`t •,
•�jyF '��d1 ay��;;S� �.-1 �r, d1y.�,L,it � .`hf�{, I S3 + .I•-_-` � • •, � � •xr. 1- f r� 1 �• r. . ., •�' •' '� u. �`"_
\:� a�-�fY +')":•O'T'rrr.:Yh� i; 2♦y ', I _ 1� •; '�1�� r 1 � �ti.-._��:R� ',�'C,r'4 .�x4 -_
I K t! ��! J, �, rl ^tr {'• 1 ..I Orr y' �_ ..1� •.a^�G.ji 11
d.irJJJJ.'.'tt;�V��'���Y"�''�- f' :*`�,►" i.hr. ° �'" i=`' r•"-�. ' ' r'+!r �ah,�n �T �i i c t"fir v, ti r
WAR *• ( �. _ { 7•
rs t 1. r �: v,+ldi +r+ b0' � r.�. 4 :•t�,�r r f 1 � ,r I '.,.f" ,w' t d 1
•r lif.,p�- ek r ,ri•I�F („ ^�.�lr.. ��,}�, a ;. .c: ,M1� .ri_ �- r�i, �.� �4--i-�',r�i+,��;,�+,�4.. � �.4.. ;.,t, ;' �`! � ..�1�- r,n -d'
'+v,...5 •� ���w+ V ,� r., I x'�' ,� .,r' ,;' �. �+ �� r.'.•, �1�( I. �.j �r- s;, �; 'T�l i, 4 0 '.r . ;
(�• ,tit;'-,+yt `•^ jr _},',i klx:iS :x ;'ivb_ - ,..ISt ,'!+9 6l✓" if.�{"Ih:e Rd�/liS. lif �: �: i"I R .t4�i ,S•i'�7 "� ,
t,ll ,�`, rr�l.y�„�yr if rrl �. rr �bi,'�`e:,}i> �Y i 1�� - .( � r f 11 •� ..y,�l ts �'. sir• 1� � rr'' I t
'�h';�4�;''��, ���!J� `f�. i!'i�'1S j vrr � 'i��� / sr Il �y �•-r ', U - :� r'L'tr �' q-,h rh �' �5'�ii-S; �N'.�'f! i �• �Izr...}}}���,,,5 . 1i'f'.. �. ,a." � .
j✓ lea 0s?^r" t.. !1A1�:LLivl ,!x , 5Y'`' ,r, ad r) ►t - a i, # /• f ' '' +-r`J%'�, ' , t�'._ F (. }°.; t_- -� a. f �--, .� .r , �.•` -.1 r
z r4}� Yi�'G "1?:'!C 4':. ' ,- '},�. � �, l ' a ; : _ • [ �KL� , �' '�frr TSY.tji� r � 1�„ I .S .4 a• ± ( -� .
. •,� iz+N'G + f11�;, r ' �� - '[ � r 1' t r .,� r� �'�,, :rr "'i�, •�.y �; �; .�•L•df _ '•'sib +^- ��
r'; ; rr,. tlrry tY 1 SlT f .. S' y
_ ,.�„ t �._r. �t i ,r.Y:>. �C� `r' ✓y'M: .. :1• irk, .'d+ C�"rJ~ Y n ,,' " k'' t�'(•17J'.• I
�{, • v `,,j", j rt.rr
�. ,� 'Q5r'd��C .,i:'; r "1 +f • i- _ ,.�*.4 -.*i� ��. .r(,t � •-.a. � i t 1-Ss1• � (� l\ `
'r,.
V,'.�r.`

s
A
EMERGENCY ACTION PLAN
PHONE ERS
DwQ �o b y!
E1ERGEVCY MANL AG0V= SYSTEM 911
SWCD _6110 8&A &g3G
MRCS ku a. 9 3 l
=This plan will be implemented in the event that wastes from your operation are lealang,
overflowing, or running off site_ You should not wait until wastes reach surface waters or leave
your property to consider that you have a problem. You should make every effort to ensure that
this does not happen. This 121an_should be nested in an gccesale location for all lgy.= at the
fly- The following are some action items you should take.
1. Stop the release of wastes. Depending on the situation, this may or may not be possible.
Suggested responses to some possible problems are listed below.
A Lagoon overflow—possible solutions are:
a- Add sod to berm to increase elevation of dam.
b. Pump waste to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B. Runofifrom waste application field -actions include.-
a.
nclude:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reasons) that caused the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.

D. Leakage from flush systems, houses, solid separators -action include:
a Stop recycle pump.
b. Stop irrigation pump.
c. Make sure no siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
e. Repair all leaks prior to restarting pumps.
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed to Sowing
leaks -possible action:
a. Dig a small well or ditch to catch all seepage, put in a submersible pump, and pump
back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill holes and
compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon bottom as soon
as possible.
2. Assess therextent of the spol and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what duration?
c. Any damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off of the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. Duringmal business hours, call your DWQ (Division of Water Quality) regional office;
or
Prone After hours, emergency number: M 133 a3yzYour phone call
should include: your name, facility, telephone number, the details of the incident from item
2 above, the exact location of the facility, the location or direction of movement of the spA
weather and wind conditions. The corrective measures that have been under takers, and the
seriousness of the situation.
b. If spill Ieaves property or enters surface waters, call local EMS Phone number 911.
c. Instruct EMS to contact Iocal Health Department.
d. Contact CES, phone number, RIs( W V 97t, local SWCD office phone number
and local MRCS office for advice/technical assistance phone number
4. If none of the above works, call 911 or the Sheriffs Department and explain your problem to
them and ask that person to contact the proper agencies for you.

5. Contact the contractor ofyour choice to begin repair of problem to minimize off-site damage_
a. Cant -actors Name:
b. Contractors Address:
c. Contractors Phone:
5. Contact the technical specialist wcertified
who the lagoon (MRCS, Consulting Engineer, etc.)
a. Name: �31.. 46J 6e,�%A t�
b. Phone: 00q 10 6-q
7. Implement procedures as advised by DWQ and technical assistance agencies to rectify the
damage, repair the system, and reassess the waste management plan to keep problems with
release of wastes from happening again.

il•Iortality Management 1'lethods
(check which methods) are bein4g implcmcnted)
* Burial three feet beneath the surface of the ground within 24 hours after
knowledze of the death. The burial must be at bast 300 feet from any flowing
stream or public body of water.
Rende.in2 at a rendering plant licensed under G.S. 106-163.7
❑ Complete incineration
❑ In the case of dead poultry only, piacinY in a disposal pit of a size and'desiQn
approved by the Department of A_riculture
❑ Any method which in the professional opinion of the State Veterinarian would
make possible the salvage of pan of a dead animal's value without endangering
human or animal health. (written approval of the State Veterinarian must be
attached)
Insect Control Checklist for Animal Operations
i1111rCC Omsc 111191's to coulrol lllscels Silc Specific Practices
Liquid Systems
Flush Ciuncrs Accumulatimi of solids ❑ Flush system is designed and operated
suflicically to renlovc aeculnulaled solids iron►
gullers as dcsignd.
❑ Itentovc bridging of acculuulaled Solids ilt
disgharge
L.IgOulls Mill PIIS • cruslud Solids 0 Malilhlill iagonns, settling busins and pits %vUr4
pest breeding is alipareal to miniudze the
crusts iC of solids to a depth of Ito rnorc plan 6 -
8 inches over more Ulan 300/6 of surface.
Exce5aivc Vegutalive t)ecayint; ve1;C1110 111 0 Maintain vugoalivc control alang banks of
I ilo+vlll lagnons and oilier inlpoundnellts to prevcnl
accunllllation of decayhlL Vegetalive matter
along; water's edge on inlpollntdnGll's perinlulcr.

Swine Farm Waste Management Odor Control Checklist
suurcc Cause IIMPs to hilliltuice odor Silt Specific Practices
1 annslLad Swine producliols CI Vegetalive or wooded buffers;
C1 I(ecolmnended best managemeal practices;
L-1 Good judgment and common sense
Animal body surfaces • Dirly manure -covered animals C7 Dry floors
FICwI'Slit l'1iL:cs 4 Wel trt:ature-covered Ilours Cl Slotled floors;
n Waterers located over slolted floors;
D Feeders at high end of solid floors;
Cl Scrape manure buildup from floors;
CI Underfloor ventilation for drying
Hanoi Collection pits • Urine; n- Frequent numure removal by flush, pit recharge,
V Parlial microbial decomposition or scrape;
n Underfloor ventilation
Velntl,111on c\l ausl lulls • Voliltllc gases; Ill Ell, maintenance;
111051 n Ufficienl stir movement
Iutluur slufac►s 6 Dust Cl Wasltdown between groups of animals;
n Deed additives;
n Feeder covers;
11 Deed delivery downspout exlcntlers lo feeder
covers
flush lank, Agilatiun of recycled lagoon CI Flush lank covers;
liyui(I while lacks are filling ❑ Extend fill lines to near bottom of Tanks with
anti-sinllon vents
Flush alleys • Agitation (luring waslewalcr n Underfloor fltlslt wilb underfloor vcWHaliuu
conveyance
Vil Icch,nl;c points • Agitation of recycled lagoon Cl Extend reclntrue lines to near bottu0l ul'l}ils
1111UnI while pits are filling Willi ami -siphon vents
Lilislal SAgiladon during sump lank n- Suntlt lank. covers
filling and drawdown
nillsidk: drrtin colicclion Agitation during wastewater f;l Ilox covers
ur Junction buxes conveyance
Alvltlt; - November 11, 1996, Page 3

Source Cause BM1's to Minimize Odor Re Specific Practices
End of drainpipes at • Agilalion during wastewater M Emend discharge point of pipes underneath
lagoola conveyance lagoon liquid level
Lagoon surfaces • Volatile gas emissions; ❑ proper lagoon liquid capacity;
• Biological mixing; ❑ Correct lagoon slartup procedures;
• Agitation ❑ Minimum surface area -lo -volume ratio;
Cl Minimum agitation when.pumping;
❑ Mechanical aeralion;
Cl Proven biological additives
lit igatioa sprinkler 0 1ligh pressure agilalion; ❑ Irrigate on dry days with little or no wind;
nozzles • Wind drift ❑ Minimum recommended operating pressure;
Cl Pump intake near lagoon liquid surface;
Ci Pump from second-slage lagoon
SturatIv t;mk or basin • Partial microbial decomposition; Cl lioltnrli or nlidlcvel loading;
sllrlacc • Mixing while lilling., ❑ Tunk covers;
Agitation when emptying ❑ Basin surface mals of solids;
Cl Proven biological additives or oxidants
Setaliai; basin surface;
•
Partial microbial decomposition;
Cl
Extend drainpipe outletS underaealll iicplid
•
Mixing while filling;
level;
Agitation when emptying
Cl
Remove settled solids regularly
A-L•aaure, slurry ar sludge
.
Agitation when spreading;
Ci
Soil injection of slurry/sludges;
!.III ealler outlets
0
Volatile gas emissions
0
Wash residual manure from spreader after use;
❑
Proven biological additives or oxidants
Ilacovered manure,
Volatile gas emissions while
❑
Suil injection of'sImrylsludges
slurry or sludge on field
drying
M
Soil incorporation within 48 llrs.;
sol fiaces
n
Spread in thin uniform layers for rapid drying;
❑
Proven biological additives or oxidaws
Deal inlituals
Carcass decomposition
❑
Proper disposilioll ol,carcasses
DC;111 allimal dkimsal
Carcass decomposition
❑
Complete covcrnlg of Carcasses Ili kirrd pias;
[)its
n
Proper location/ennswiction nfdisposal pits
111611 MMS
•
Incomplete Combustion
n
Secondary slack Illlrlll:rs
AMC C - Movuluber 11, 1996, Pagel

.:
Source - - Cuuse 11MI's to Mluinrice Odor _ Sile Specific Pracliecs
Siawlinl; wider around • Improper drainage, 0 Grade and landscape such Ilial water drains
facilities • Microbial decomposition of away from facililies
organic matter
hlanure tracked onto • Poorly maintained access roads ❑ fano access road mainlenancu
public roads iiom farm
access
Additional Information : Available From :
Swine f` amire Management ; 020n IWIcmMP Packet NCSU. Cirunty ExIensiun Cenler
Swine Production Farm Potential Odor Sources and I(emedic;s ; EIIAE Fact Sheet NCSIJ - IIA H'
Swine Production Facility Manure Management: Vit 11rcllarge - Lagoon Trcalmeal ; FIIAE 128-88 NCSU - IIAfi
Swine Pr<xluction Facility Manure Marnagemeol: (Underfloor Flash - Lagoon Trealnent ; EBAIi 129-88 NCSU - IIAE
Lugotm Design and Ivlanagemenl for Livestock Manure'freatmeal and Storage ; EIIAE 103.83 NCSIJ - BA
Calibration of Manure and Wastewater Application Equilpntctnt ; FBAE Fact Sheet NCSIJ - BA I:
Cuurroiling Odors from Swine lluildings ; PI11-33 NCSIJ - Swine Extension
i:uvironmenial Assurance Program ; NI'I'C Manual NC fork Producers Assoc
Options fi)r Managing Odor; a report from the Swine Odor Task Force NCSIJ Agri Communications
fluisance CIIIICeraIS in Animal Manure Management: Odors and Flies ; Pit0107, 1995 Conference. Proceedings Florida Cooperative ExIension
ANWC- Noyt:mher 11, 1996, Pat;L:5

REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff drift, manmade conveyances, direct application, or direct
discharge during operation or land application. Any discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the producer either owns or has a notarized agreement for use of
adequate land on which to properly apply the waste. If the producer does not own adequate land to properly dispose of waste,
he/she shall provide a copy of a notarized agreement with a landowner who is within a reasonable proximity, allowing him/her
the use of the land for waste application. It is the responsibility of the owner of the fkcUity to secure an update of the Waste
Utilization Plan when there is a change in the operation, increase in the number of animals, method of utilization, or available
land.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for realistic crop yields based on soil type, available
moisture, historical data, climate conditions, and level of management, unless there are regulations that restrict the raze of
application for other nutrients. Actual yields may be used in lieu of realistic yield tables at the discretion of the planner..
4. Animal waste shall be applied on land eroding less than 5 tons per acre per year. Waste may be applied to land that is eroding
at more than 5 tons but less than 10 tons per acre per year providing grass filter strips are installed where runoff leaves the
field (See FOTG Standard 393 -Filter Strips)
5. Odors can be reduced by injecting the waste or disking after waste application. Waste should not be applied when'there is
danger of drift from the irrigation field.
b. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated on conventionally tilled cropland
When applied to conservation tilled crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff does not occur off-site or to
surface waters and in a method which does not cause drift from the site during application. No ponding should occur in order
to control odor and flies.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the surface is frozen.
9_ Animal waste should be applied on actively growing crops in such a manner that the crop is not covered with waste to depth
that would prohibit growth. The potential for salt damage from animal waste should also be considered.
10. Waste nutrients shall not be applied in tall or winter for spring planted crops on soils with a high potential for leaching Waste
nutrient loading rates on these soils should be held to a minimum and a suitable winter cover crop planted to take up released
nutrients. Waste shall not be applied more than 30 days prior to planting of a crop or forages breaking dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following: The outer perimeter of the Iand area
onto which waste is applied from a lagoon that is a component of a swine farm shall be at Ieast 50 feet from any residential
property boundary and from any perennial stream or river other than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995, shall not be applied closer than 25 feet to surface water. This
distance may be reduced for waters that are not perennial provided adequate vegetative filter strips are present (See Standard
393 - Filter Strips).

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
12. Animal waste shall not be applied closer than 100 feet from wells.
1 I Animal waste shall not be applied closer than 200 feet of dwellings other than those owned by landowner.
14. Waste shall be applied in a manner not to reach other property and public right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided it has been approved as a land applications site by a
"technical specialist". Animal waste applied on grassed waterways shall be at agronomic rates and in a manner that causes no
runoff or drift from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall not be discharged into the animal
waste management system.
17. A protective cover of appropriate vegetation will be established on all disturbed areas (lagoon embankments, berms, pipe runs,
etc.). Areas shall be fenced, as necessary, to protect the vegetation. Vegetation such as trees, shrubs, and other woody
species, etc. are limited to areas where considered appropriate. Lagoon areas should be kept mowed and accessible. Lagoon
beans and structures should be inspected regularly for evidence of erosion, leakage, or discharge.
18. If animal production at the facility is terminated, the owner is responsible for obtaining and implementing a "closure plan"
which will eliminate the possibility of an illegal discharge, pollution and erosion.
19. waste handling structures, piping, pumps, reels, etc., should be inspected on a regular basis to prevent breakdowns, leaks, and
spills. A regular maintenance checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it should only be applied preplant with no finther applications of
animal waste during the crop season.
21. Highly visible permanent markers shall be installed to mark the top and bottom elevations of the temporary storage (pumping
volume) of all waste treatment lagoons. Pumping shall be managed to maintain the liquid level between the markers. A.
marker will be required to mark the maximum storage volume for waste storage ponds.
22. Soil tests shall be made every two years, and a liquid waste analysis shall be takenAe 6p dconst i ent with
waste utilization plan. Poultry litter shall be tested prior to application. Soil and waste analysis records shall be kept for five
years.
Dead animals will be disposed of in a manner that meets NC regulations_

c
_ __:��.BR�1rN'S.
CAROLINA. -
BROWN'S OF CAROLINA FARM #28
4000 FARROW TO WEAN
STATE ROAD #211 - BLADEN COUNTY
DIRECTIONS: FROM CLARKTON, TAKE HIGHWAY #211 SOUTH TOWARD
BOLTON. FARM WILL BE ON LEFT APPROXIMATELY 3 MILES FROM CLARKTON.
MAILING ADDRESS: SHIPPING
BROWN'S OF CAROLINA FARM #28 BOC 928
P.O. BOX 487 STATE ROUTE #211
WARSAW, NC 28398 CLARKTON, NC 28433
WORK: [phone]
m-RCV,l,'J S OF CAR3LINlA.!lJC
303 EAST COLLEGE STREET - P.O Box487 - 2?398-0487 - OFFICE. [phone] * FAX[phone]
UZI
Lm
tma
Lza
r Ile! i
un
JSPVw
YI
Irk
Lj Ir
ski- ch,
DIRECTIONS: FROM CLARKTON, TAKE HIGHWAY #211 SOUTH TOWARD
BOLTON. FARM WILL BE ON LEFT APPROXIMATELY 3 MILES FROM CLARKTON.
MAILING ADDRESS: SHIPPING
BROWN'S OF CAROLINA FARM #28 BOC 928
P.O. BOX 487 STATE ROUTE #211
WARSAW, NC 28398 CLARKTON, NC 28433
WORK: [phone]
m-RCV,l,'J S OF CAR3LINlA.!lJC
303 EAST COLLEGE STREET - P.O Box487 - 2?398-0487 - OFFICE. [phone] * FAX[phone]

XAS 2 -MAN7.GMMST 21-Lii C!KRTM7=C.ATIO2i FOR NZW OR E-7 A== Y=Lo,:s
Plaane =aty= t~a c=Vlatad fora to tee Divisio= of Ma-ag--t at
tha add=esa C= t_ -e =eve=s• sides of tea fo=_
Fa= location: Latitude and Long itude:'r/'`(reguired) • A?so,
please attach a copy of a county road map with locatioi% idea -ti fled.
'i`re of operation (swine, layer, damn, etc -1: -:!5'Crl
Des igrx ca -ac; ty (neer of ani—els) :15d'WS "6 - -Pet ^J
Average size of operation• (12 mont"h po=ulat4on avg.) 4CI 5040-5-
Average acreage needed for land appli.catior_ of waste (acres): O .S
�vav����=aavvvvv�s�T3vvv�n�vvaaaasasazaaasaaaasvaav:avv3aaaaaaaaa�a=3asaa3avaa
As a cac:z.ical specialist designated by the North Carolina Soil and Water
Cons e_,ration Co=missior_ pursuar_t to 15A NCAC 6= .0005, I certify that tate new or
expa..ded animal waste management system as installed for the fax -m. n—ed above
has an arimzl waste management plats that meets the design, carst_sction,
ape=ation and maintenance standards and specifications of tze Division of
Znvironmental Manage-ment and the USDA -Soil Conservation Service and/or the North
Carolina Sail -and *Mater Corse=nation. Commission pursuant to ISA NCr.0 2H.0217 and
ISA NCAC 6F .0001-.0005. The following elements and their corresponding minimum
truer'_--haxae_been verified by me or other designated technical specialists and
are included in the plan as applicable. miniraum separations (buffers) ; liners or
ems,;valent for lagoons o_ waste storage ponds; waste storage capacity; adeTsate
quantity and aracumt of land for waste utilization (or use of third party) ; access
Cr ow=e,ship of proper waste application equipment; schedule for timing of
acplicat'-ons; application rates; loading rates; and the control of the discharge
of pollutants from stogywater r-_moZf events less severe than the 25 -year, 24-hour
storm.
ha=q o= c �Spatia?
Address (A cy) c , _ iFr'S%�h�_ ./iJ Phone No. /U = o'k�3 3cnCJc
S,gnatur r{ 41 4 / ,' Dat a:� ZZ -!25-
2_4 J 5
-.a vasaa ��r3aaacC37 zea aaia37 a.ssaysvasaaaa»a�a��=aaaav3aaanviaaaa3a
c'.r_e= /if &=415;Q-7/ i
A�asnaa=
I (re) u.ndstand th eration and maintenance proced- es established in the
aporoved animal waste marage_rie_^.t plant for the fa�^n named above and will i=Plement
these procedures. I (we) know- that any additional expansion to the existing
design capacity of the waste t_eat.sent and storage systa*a or construction of new
facilities will ret ire a new certification to be suhmitted to the Division of
Envi,on= ental Management before the new animals are stocked. I (we) alSa
unde=st:and that c -ere -must be no discharge of a_nL—.al waste fr m tills system to
surface waters of the state either through a man --made conveyance or through
runoff from a story event less severe than the 25 -year, 24-hour storm. The
approved plan will be filed at the fa --3 and at the office of the local Soil and
Water Conservation Dist=ict.
r�-
Ha-a of T- d Ow=e= (Pleas P_'nt) Bl&:_Lzr', 5 c` Ox_fe(�
Signature' Q� Date: - le
.Fame of -a-agar, i`= differant: f7== owner (Please prat)
Signature: . Date:
?Tote: A change in land ownership re(:ruires notification or a new certification
(i_ the a_praved plan is c ;angel) to be suh..mitted to the Division of
Environmental Ma.agame nt within 60 days of a title t=arsfer.
DE24 USE, ot'iY:AC�Md*

NUTRIENT MANAGEMENT PLAN
Grower(s):
Fane Name:
County:
Farm Type:
Farm Capacity:
Storage Structure:
Storage Period:
Application Method:
Brown's of Carolina
Farm 28
Bladen
Far -Wean
4000
Anaerobic Lagoon
180 days
Irrigation
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
Page: 1

5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy: Injecting the waste or
disking will conserve nutrients and reduce odor problems.
This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimism range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft3, tons, etc.):
4000 animals X 3212 gal/animal/year =
12848000 gallons
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs):
4000 animals X 5.40 lbs/animal/year = 21600 lbs
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
Page: 2

The following acreage will be needed for waste application based on the crop to be grown,
soil type, and surface application.
Tract
Field
Soil
Type
Crop
Code
Yield
/Ac
Ibs N
/unit
Acres
Lbs N/Ac
Residual
Lbs N
, !Ac
I Ibs N
Required
715.00
Time to
Apply
Mar -Oct
4737
10
ExA
C
6.5
50.00
2.2 325.0
4737
S
AyB
C
6.3
50.00
9.0 1315.0
2835.00
Mar -Oct
4737
9
ExA
C
6.5
50.00
2.5 i 325.0
812.50
Mar -Oct
4737
6
ExA
C
6.5
50.00
3.3 ( 325.0
1072.50
Mar -Oct
4737
4
ExA
C
6.5
50.00
3.4 i i 325.0
1105.00
Mar -Oct
4737
7
ExA
C
6.5
50.00
3.3 1325.0
1056.25
Mar -Oct
4737
un15
ExA
C
6.5
50.00
13.0 325.0
4225.00
Mar -Oct
4737
un12
ExA
C
6.5
50.00
25.0 325.0
8125.00
Mar -Oct
4737
11
ExA
C
6.5
50.00
2.0 325.0
650.00
Mar -Oct
4737
--10
ExA
K
50.00
2.2 50.0
1 110.00
S April
4737
-8
AyB
K
50.00
9.0 50.0
j 450..00
S -April ,
4737
-Y9
ExA
K
50.00
2.5 50.0
125.00
S -April
4737
-6
ExA
K
50.00
3.3 50.0
165.00
S -April
4737
-r4
ExA
K
50.00
3.4 50.0 1
170.00
S -April
4737
-7
ExA
K
50.00
3.3 50.0 i
162.50
S -April
4737
--un15
ExA
K
50.00
13.0 50.0 i
650.00
S -April
4737
-un 12
ExA
K
50.00
25.0 50.0
1250.00
S -April
4737
--11
ExA
K
50.00
2.0 50.0
i
100.00
S -April
Total 63.7
Available N
*Difference
23778.75
21600.00
-2178.75
--indicates that this field is being overseeded (i.e. interplanted) or winter annuals follow summer
annuals.
*A negative number reflects the total lbs of additional nitrogen needed to achieve yields on
acreage listed in chart. A positive number means additional acreage is required to utilize the
nitrogen produced by the fans.
NOTE:
This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
I
Page: 3

The applicator is cautioned that tj and K may be over applied while meeting the N requirements.
In -the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This pian only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want .to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of.
about two inches before drilling for best results.
The following legend explains the crop codes listed in the table above:
Crop Code ro
-121
A
Barley
B
Hybrid Bermudagrass - Grazed
C
Hybrid Bermudagrass - Hay
D
Com - Grain
E
Com - Silage
F
Cotton
G
Fescue- Grazed
H
Fescue- Hay
I
Oats
J
Rye
K
Small Grain - Grazed
L
Small Grain - Hay
M
Grain Sorghum
N
Wheat
O
Soybean
Lbs N utilized / unit yield
1.6 lbs N 1 bushel
50 lbs N 1 ton
50 lbs N 1 ton
1.25 lbs N 1 bushel
12 lbs N 1 ton
0.12 lbs N / lbs lint
50 lbs N 1 ton
50 lbs N I ton
1.3 lbs N / bushel
2.4 lbs N 1 bushel
100 lbs N / acre
133 lbs N / acre
2.5lbs N/cwt
2.4 lbs N / bushel
4.0 lbs N / bushel
Page: 4

Acres shown in the preceding taole are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 0.84 pounds of plant available nitrogen per animal per year in the
in sludge based on the application method listed earlier.
If you remove the sludge every 5 years, you. will have approximately 16800.00
pounds of PAN to utilize. Assuming you apply this PAN to hybrid bermudagrass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 56.00 acres of land. If you apply
the sludge to corn at a rate of 125 pounds per acre, you will need 134.40 acres of land.
Please be aware that these are only estimates of the PAN and land needed. Actual requirements
could vary by 25% depending on your sludge waste analysis, soil types, realistic yields, and
applications.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
The following is provided as a guide for establishing application rates and amounts.
Page: 5

•
Tract
Field
Soil
Type
Cro
Application Rate Application Amount
in/hr ' inches
4737
10
ExA
C,K
_......_.------
0.35 1.50
4737
8
AyB
C,K
0.35 1.20
4737
9
ExA
C,K
0.35 1.50
4737
6
ExA
C,K
0.35 1.50
4737
4
ExA
C,K
0.35 1.50
4737
7
ExA
C,K
0.35 1.50
4737
un15
ExA
C,K
0.35 1.50
4737
un 12
ExA
C,K
0.35 1.50
4737
11
ExA
C,K
0.35 1.50
*This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for 180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsiability of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
Additional Comments:
Page: 6

NUTRIENT MANAGEMENT PLAN CERTIFICATION
Name of Farm:
Owner/Manager Agreement:
Brown's of Carolina, Farm 28
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved "animal waste nutrient management
plan for the farm named above. l/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
ltwe understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described'in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner:
Signature:
Brown's of Carolina, Inc.
Name of Manager (if different from owner): OT I.e- K,
Please Print
Signature:
Name of Technical Specialist:
Affiliation:
Address:
Signature:
Telephone:
Jimmy R. Vinson
Brown's of Carolina, Inc.
P.O. Box 487
Warsaw, NC 28398
[phone]
Date
Date
Date
Page: 8

R
, ji
s
IN6 effoNiqn.
coo
. A;
C
—.v-
lo'
9.11
1.6
6A.-qr.
, o
S� "t
I-K
�a
Iq .1
pl; 9 ZZ
?A.
0,41 11"z
A:- Lk
e'r -VA ­g
J(4.
of
AA�
4 1
k4

it
I :r
EMERGENCY ACTION PLAN -
PHON��Jjoqfb ERS
DWQ
EMERGE1"CY KA_NL AGEstitENT SYSTEM 911
S WCD _ q'(o &o ;k 60-936
MRCSk(P a. 613 i6
-"This plan will be implemented in the event that wastes from your operation are leaking,
overflowing, or running off site. You should not wait until wastes reach surface waters or leave
your property to consider that you have a problem. You should make every effort to emsure that
this does not happen. nisn�,ShQuld be posted in an ag;esMjle location for all e=lovcz at The
facility. The following are some action items you should take.
1. Stop the release of wastes. Depending on the situation, this may or may not be possible.
Suggested responses to some possible problerns are lined below.
A. Lagoon overflow—possible solutions are:
a_ Add soil to bean to increase elevation of dam.
b. Pump waste to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Call a pumping contractor.
e. Make sure no surface water is entering lagoon.
B. Runoff from waste application field -actions include:
a- Ir,- nediateIy stop waste application_
b. Create a temporary diversion to contain waste.
C. Incorporate waste to reduce runoff_
d. Evaluate and eliminate the reasons) that caused the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinklers -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.

D. Leakage from flush systems, houses, solid separators -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure no siphon occurs.
d. Stop all flows in the house, flush systems, or solid separators.
e. Repair all leaks prior to restarting pumps.
E. Leakage from base or sidewall of lagoon. Often this is seepage as opposed to flowing
leaks -possible action.
a. Dig a small well or ditch to catch all seepage, put in a submersible pump, and pump
back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill holes and
compact with a clay type soil.
c. Have a professional evaluate the condition of the side walls and lagoon bottom as soon
as possible.
2. Assess the. -extent of the spill and note any obvious damages.
a. Did the waste reach any surface waters?
b. Approximately how much was re?eased and for what duration?
c. Any damage noted, such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off of the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. DuringEikl
business hours, call your DWQ (Division of Water Quality) regional office;
Phone f Afterhours, emergency number: 919 13-3 agy Your phone call
should include: your name, facility, telephone number, the details of the incident from item
2 above, the exact Iocation of the facility, the location or direction of movement of the spill,
weather and wind conditions. The cbrrective measures that have been under taken, and the
seriousness of the situation.
b. If spill leaves property or enters surface waters, call local EMS Phone number 911.
c. Instruct EMS to contact local Health Department.
d. Contact CES, phone number U a2-7 li, local SWCD office phone number
and local MRCS office for advice/technical assistance phone number
4. If none of the above works, call 911 or the Sheriffs Department and explain your problem to
them and ask that person to contact the proper agencies for you.

f 5. Contact the contractor of your choice to begin repair of problem to minimize off-site damage.
a_ Contractors Name:
b. Cant -Actors Address:
c. Contractors Phone:
6. Contact the technical specialist who certified the lagoon (MRCS. Consulting Engineer, etc.)
a. Name:
b. Phone:
7. implement procedures as advised by DWQ and technical assistance agencies to rectify the
damage, repair the sy5tert, and reassess the waste management plan to keep problems with
release of wastes from happening again.

Mortality Management N-lethods
(check which method(s) arc beim, implemented)
' I Burial three feet beneath the. surface of the ground within 24 hours after
kno%vlcdgc of the death. The burial must be at least 300 feet from any flowing
stream or public body of Water. -
Rendcrine at a rendering plant licensed under G.S. 106-163.7
Complete incineration
❑ In the case of dead poultry only. piacing in a disposal pit of a size and' design
approved by the Department of A--nculturc
:.1 Any method which in the professional opinion of the State Veterinarian would
make possible the salvage of part of a dead animal's value without endangcrin-
human or animal health. (Written approval of the Slate Veterinarian must be
attached)
Insect Control Checklist for Animal Operations
Source Cause IMPS to coulrol Insects Sill: specific Pracliccs
Liquid Systems
1`111A 0111lers • Accumulation orsolids 0 Mush system is designud and uperaled
suflicicnlly In remove accannilaled solids from
gutters as designed.
0 Itcnlove bridghlg of acctulit11iltcd solids ill
discharge
t.aLnuos and toils • crusled Solids © Maiuluin IaGonus, sellliug basins and Mils where
pcsl brCeding is apparent to n►iniolize lite
crusling of solids In a depth of no More than 6 -
8 inches over more than 30% of surface.
l:aceasivc veuclalive DecuyiuG vegulaliull Cl Maintain vegetative conlrol along Banks or
l lukVill lagaons and ether impoundments In prevent
accumulation ofdccayin vegetative matter
-dont; %vater's udGc on imliounilmcnI's perimcler.

0
Swine Farm Waste Management Odor Control Checklist
source
Cause
Cl
11MPs to Mlllinaice 011ol' Silt: Specific Pr(acticu:s
I'al ill Stem1
• Swille production
L1
Vegetative or wooded buffers;
D
Recommended best nlanagelllelll practices;
0
Good jndgment and cornmon senso
Animal burly surfaces
a Dirly manure -covered animals
O
Dry floors
Flour aulf..Iccs
• Wcl luautlre-covered Iloors
5-
simied Iloors;
n Walcrers Ir,catcd over sloped floors;
Ll Feeders at high end of solid floors;
L1 Scrape manure buildup from floors;
L'1 Underfloor ventilation for drying
Hanoi k: collection pits 0 Urine; Ll fre(luem malture removal by flush, pit recharge,
• Parlitd microbial decouaposilion or scrape;
0 Underfloor ventilation
Verllif,Lliun call lsl lAJIS I Vlllalile gaSeS; Ci mall Inaintellialce;
(hist n Efficient .lir movement
Induur surfaces
Dust
Cl
Washdown between groups of animals;
17.1
I'ecd additives;
El
l-ccder covers;
Cl
l'ced delivery downspoul extenders In fecder
covers
l-'lusb tanks
Agitation of rt:cycled lagoon
LI
I'lusll tack covers;
liynid while: tanks arc filling
Cl
Extend fill lines to near hollom of Iillda wilb
ami -siphon vents
V Ioslu alleys
Agitation (luring WilSIGwillCr
[i
Underfloor flush willI untferlluol' ventilation
conveyance
Pil lecliarge points
• Agitation of recycled lagoon
L7
I:xlciul recharge lines io near boalum ul'llils
liquid while pits are filling
with unli-siphon vents
LiCi Agitation thlr'ing sunup Iauk n Somp hulk covers
filling and drawdown
IIuISi+h drain cullcctiuu • Agitaliun ebbing wastc►vater 5- nox covers
ur juliction boxes colrveyarlcl:
November 11, 1996, Page 3

Source Cause 13MI's to Minimize Odor Site Specific Practices
End of drainpipes al Agitation during wastewaicr Cl Extend discharge point of pipes underneath
lagnor conveyance lagoon liquid level
t.a};utYn surfaces
• Volatile bas emissions;
• Biological mixing;
• Agitatioo
CI Proper lagoon liquid capacity;
O Correct lagoon slarlup procedures;
* Minimum surface arca-to-voltmlc ratio;
art Minimum agitation when.plimping;
Cl Mechanical aeration;
n Proven biological additives
lrrigatiur spritdacr • high pressure agitation; 0 Irrigate on dry days with little or no wind;
nozzles 0 Wind drift 1 Cl Mininutm recommended operating pressure;
Cl Pump intake near lagoon liquid surface;
Cl t'ump from second -stage lagoon
SYueagn tank Of kkSir • Pariial microbial decumpusiiicYr; 5 linttom or midlevel loading;
surf. -4e 0 Mixing while filling;
C7 'Tank covers;
• Agitation when emptying 0 Basin surface mats of solids;
CI PrnVClt biological additives or nsidi'ults
Uclul amulets Carcass decomposition ❑ Proper disposition of carcasses
^Reuel ariuY.11 diSposul Carcass decompusiliou Ci Complete covering of carcasses in I,uri.Yl pits;
lues
Iue:in�:e��nnuS • IIIeUIIlplelC CllllllnY5111N!
AMOC - Noveauher 11, 1996, Page,I
M Proper location/conslroction ol'disposal pits
5 Secondary slack Imrners
C7
Proven biological arhlitives or oxitlaws
Sculiug baSin SUflin:e •
Partial microbial decomposhioYY;
C1
limund drainpipe outlets uu lerueatlr liquid
•
Mixing while filling;
level; ,
•
Agitation when emptying
Cl
Remove settled solids regularly
M.murc, slurry or sludge •
Agitation wlYctr spreading;
a-
Soil injection of slurry/sGulges;
slueuder outlets
Volatile gas emissions
CI
Wash'residual manure from spreader after use;
M
Proven biological wk ilives or oxidams
011covercd maourc, •
Volatile: gas emissions while
Cl
Suil injeclion ol'slurrylsludges
slurry or sludge on field
drying
n
Soil incorporalion within X16 hrs.;
slit l ie cs
n
Spread in thin uniform layers for rapid drying;
CI PrnVClt biological additives or nsidi'ults
Uclul amulets Carcass decomposition ❑ Proper disposition of carcasses
^Reuel ariuY.11 diSposul Carcass decompusiliou Ci Complete covering of carcasses in I,uri.Yl pits;
lues
Iue:in�:e��nnuS • IIIeUIIlplelC CllllllnY5111N!
AMOC - Noveauher 11, 1996, Page,I
M Proper location/conslroction ol'disposal pits
5 Secondary slack Imrners

Source Cause 111411's to Mlnirnixe Odor Silt Specific Pr•aclires •
Standing water around • Improper drainage; Cl Gracie and landscape such that water drains
facilities . Microbial decomposilion of away from litcililies
organic maller
hhoure tracked onto • Poorly maintaincd access roads Cl Tann access road maintenance
public reads 1,30111 farm
access
Additional Informatino : Available From :
Swine Manure M,utagennettt ; 0200 Itnle/pMP Packet NCSl1, County Extension Center
Swine Production farm Poiculial Odor Sources and Remedies ; EIIAI. Fact Sheet NCSIJ - IIAE
Swine Production facility Manure Managwavil: Pit ltcellarge - Lagoon Treatment ; EBAI: 128-88 NCSIJ - HAE
Swine Production Facility Manure Management: Underfloor I-Iosh - Lagoon Treatment ; FMAE 129-88 NCStJ - IIAE
I.aguon Design and Munagemeul for Livestock Manurc Treatmem and Storage ; EIIAG 1113-83 NCSIJ - IJAli
Calibration of Manure and Wastewater Appliealiott Equipment ; E-BAE fact Sheet NCSIJ - IIAE
Controlling Odors from Swine Buildings ; PILI -33 NCSLJ - Swine Extension
Envirouncntal ASSLIMICe Program ; NPI'C Manual NC fork Producers Assoc
(]talions for Managing Odor; a report Isom dic Swine Oiler Task Force NCSIJ Agri Communications
NlliSMICe C011CUMS io Animal Manure Management: Odors and Flies ; PRO107, 1995 Conference Proceedings Florida Coupa:rative I{xlaalSiull
AA -I()(; - I44vedi1wr 11, 1996, Page S

WASTE IDM IZAIM N PLAN
REQ=D SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff drift, manmade conveyances, direct application, or direct
discharge during operation or land application. Any discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the producer either owns or has a notarized agreement for use of
adequate land on which to properly apply the waste. If the producer does not own adequate land to properly dispose of waste,
he/she shall provide a copy of a notarized agreement with a landowner who is within a reasonable proximity, allowing hinvher
the use of the land for waste application. It is the responsibility of the owner of the facility to secure an update of the Waste
Utilization Plan when there is a change in the operation, increase in the number of animals, method of utilization, or available
land.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for realistic crop yields based on soil type, available
moisture, historical data, climate conditions, and level of management, unless there are regulations that restrict the rate of
application for other nutrients. Actual yields may be used in lieu of realistic yield tables at the discretion of the planner..
4. Animal waste shall be applied on land eroding less than 5 tons per acre per year. Waste may be applied to Iand that is eroding
at more than 5 tons but less than 10 tons per acre per year providing grass filter strips are installed where runoff leaves the
field. (See FOTG Standard 393 -Filter Strips)
5. Odors can be reduced by injecting the waste or disking after waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated on conventionally tilled cropland.
When applied to conservation tilled crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding. (See "Weather and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff does not occur off-site or to
surface waters and in a method which does not cause drift from the site during application. No ponding should occur in order
to control odor and flies.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the surface is frozen.
9. Animal waste should be applied on actively growing crops in such a manner that the crop is not covered with waste to depth
that would prohibit growth. The potential for salt damage from animal waste should also be considered.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a high potential for leaching. Waste
nutrient loading rates on these soils should be held to a minimum and a suitable winter cover crop planted to take up released
nutrients. Waste shall not be applied more than 30 days prior to planting of a crop or forages breaking dormancy.
1 i. Any new swine facility sited on or after October 1, 1995 shall comply with the following. The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river other than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995, shall not be applied closer than 25 feet to surface water. This
distance maybe reduced for waters that are not perennial provided adequate vegetative filter strips are present (See Standard
393 - Filter Strips).

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
12. Animal waste shall not be applied closer than 100 feet from wells.
13 . Animal waste shall not be applied closer than 200 feet of dwellings other than those owned by landowner_
14. Waste shall be applied in a manner not to reach other property and public right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided it has been approved as a land applications site by a
"technical specialist". Animal waste applied on grassed waterways shall be at agronomic rates and in a manner that causes no
runoff or drill from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall not be discharged into the animal
waste management system
17. A protective cover of appropriate vegetation will. be established on all disturbed areas (lagoon embankments, berms, pipe runs,
etc.). Areas shall be fenced, as necessary, to protea the vegetation. Vegetation such as trees, shrubs, and other woody
species, etc. are limited to areas where considered appropriate. Lagoon area should be kept mowed and accessible. Lagoon
berms and structures should be inspected regularly for evidence of erosion, leakage, or discharge.
18. If animal production at the facility is terminated, the owner is responsible for obtaining and implementing a "closure plan"
which will eliminate the possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular basis to prevent breakdowns, leaks, and
spills. A regular maintenance checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it should only be applied preplant with no further applications of
animal waste during the crop season.
2I . MWily visible permanent markers shall be installed to mark the top and bottom elevations of the temporary storage (pumping
volume) of all waste treatment lagoons. Pumping shall be managed to maintain the liquid level between the markers. A .
marker will be required to mark the maximum storage volume for waste storage ponds.
22. Soil tests shall be made every two years, and a liquid waste analysis shall be taken �D e�consis t with
waste utilization plan_ Poultry litter shall be tested prior to application. Soil and waste analysis records shall be kept for five
years.
Dead animals will be disposed of in a manner that meets NC regulations.

North Carolina
Department of Environment and Natural Resources
Nater Pollution Control System Operator Certification Commission
Michael F. Easley, Governor
William G. Ross Jr., Secretary
Coleen H. Sullins, Chairman
February 21, 2001
Brown's of Carolina, Inc.
PO Box 487
Warsaw NC 28398
SUBJECT: Designation of Operator in Charge
Farm Name: Farm #28 (BOC)
Facility ID #: 09-155
County: Bladen
Dear Brown's of Carolina:
e��
NCDENR
,._
w . ,.
frIAR 2 7 2001
Senate Bill 1217, An Act to Implement Recommendations of the Blue Ribbon Study Commission on Agricultural
Waste, was enacted by the 1996 North Carolina General Assembly. This legislation requires owner of a certified
operator for each animal waste management system that serves 250 or more swine, 100 or more confined cattle,
75 or more horses, 1,000 or more sheep, or 30,000 or more confined poultry with a liquid waste management
system.
Our records indicate that the operator designated as the Operator In Charge (OIC) for your animal waste
management system is no longer certified. Therefore, you must designate a properly certified animal waste
management system operator as the OIC for your facility. The enclosed designation form must be returned to this
office by April 1, 2001. This office maintains a list of certified operators in your area if you need assistance in
locating a certified operator.
Failure to designate a properly certified Operator in Charge for your facility is a violation of N.C.G.S. 90A-47.2
and 15A NCAC 8F.0201 (a) and may result in the initiation of enforcement action. Please be advised that nothing
in this letter should be taken as resolving you of the responsibility and liability for any past or future violations for
your failure to have a properly certified Operator in Charge designated for your animal waste management system.
If you have questions concerning this matter, or if this office can be of further assistance, please call Beth
Buffington at [phone], extension 313.
Sincerely,
V�
Dwight Lancaster, Supervisor
Technical Assistance and Certification Unit '
Enclosure
cc: TAC Files
Non-Discharge-Compliance/Enforcement Unit
Fayetteville Regional Office
Central Files
I618 Mail Service Center, Raleigh, North Carolina 27699-1618
Phone: 919 — 733-0026 1 FAX: 919 — 733-1338
AN EQUAL OPPORTUNITY 1 AFFIRMATIVE ACTION EMPLOYER -50% RECYCLED/ 10% POST CONSUMER PAPER

A
Facility Number and Name: Brown's 9-155, Farm #28 (on original list)
e(s)
High FreeDischar boards
Ng
�' Wettable��ieresMMM
Description of Concern
INSPECTIONS
No discharges to surface waters in 2000
1/28/98 - NOV for < 19" freeboard
1/18/99 - 5/22199 <19"
11129199=18" 1213199->19"
R� ;mss
-
2/2/00- EPOA 2!7!00- I2..;`
n�
2/15/00 = l2" 21251(}0 = 16"s-
3124/00 - 19" 4127!00- POA
512100 = 16" 518100 = > 19"
6/16/00 = 17" 6126100 = 17"
� r � . r
Wo
7113/00 =>19" 814100 = 18" POA
�-
8/ 15/00 = 18" POA 8116/00=>19"
9/1/00= 16" POA 916/00= 14"
9/20100 = 14" 9125100 = 14"�
9127100 = Detail POA 1013100 = 17"
�;
_��
10/4/00 ->19" INSPECTION - 11/4199 rreeboard Inadequate
M

. YET
Discharge(s)
Hi h Freeboards
�3 R
_ ;- � W fta e es .
Response
Due to excessive amounts of rainfall from hurricanes Dennis
& Floyd and efforts to prevent discharges, the additionalMM
M_
�'em x'
water was stored in the lagoon until more favorable weather-
conditions permitted land application. This caused the liquidAN
level in the lagoon to be significantly higher than normal
gmmm � 9
._
operation levels through following winter months. Since��.
Hurricanes Dennis and Floyd, Brown's has implemented a
tt .�
;'s
number of measures designed to minimize the potential for
future freeboard exceedances and over application during
x",
-'
prolonged or severe wet weather conditions. These measures'
include water conservation, which has reduced Brown's total_`'
annual water consumption by approximately 40 percent;
5. a
��
hiring new employees; enhanced training; lagoon freeboard
�NEV.
tracking charts; and the purchase of additional equipment to
maximize utilization of our sprayfelds and avoid land
application under marginal or unsuitable conditions. Brown's
EMS, which will be ISO 14000 certified by the end of 2001,
will also contribute to improved freeboard and land'
application management.
Also, leased 180 land to increase
adjoining acres of wettable
acres available for 2001 crop year.�A
_
�_-4
Installed solid -set irrigation system to permit a reduced rate��
of a PP PP lication as well as a reduction in the total a lication
-3WR
OIN t
amount per application period and minimize potential for
runoff. Installed summer 2000. Installed pressure gages on
�-
_� tiz_
rises winter 2000._

Facility Number and Name: Brown's 9-155, Farm #28 (on original list)
M
MOE 'Z. j—,,g,7F- MT;
Over Application
Structural Issues
4�
QP SS
Description of Concern
ass.ike
3/10/97 = NOV for runoff
2/9/99 — erosion noted on d
31C /24/97 — NRE for runoff
8/21/00 = NOV/RIE for overapplication
w of PAN
8/9100 — Overapplication of PAN
SIM,
U
. I I I I I I I I I

7i7
liae-e0rains
�u"ur
Over App lication
Structural Issues
s,r mcm me
�-M - V �
A �-,.,PP!P9;MSkM
Response
M�
M M
k
Due to excessive amounts of rainfall from
Hurricanes Dennis & Floyd and efforts to
prevent discharges, the additional water was
Dike was raised to correct low spots
due to long term settlement and
minor erosion.
M ME 'AME-M-M-0-
1i 1 V7-
SO n
MV
applied to the land when soil conditions were
suitable. In order to manage freeboard levels,
11/4/99, 8/9/00 and I 1/ 13/00 DWQ
land application was accomplished during a
time when crop uptake had already been
and Soil & Water inspections
indicated
7 W3
period
met- Since Hurricanes Dennis and Flovd,
that no structures needed
Bro,.vn's has implemented a number of
.... measures designed to minimize the potential
additional maintenance or
improvement.
t
June 2001 bare areas on dike
. . . . . . . . . .
R�M-
for future fireeboard exceedances and over
application during prolonged or severe wet
reseeded.
Z5
o
weather conditions. These measures include
water conservation, which has reduced
Brown's total annual water consumption by
. . . . . .
0, M M
approximately 40 percent; hiring new
LEE-
A
employees; enhanced training- lagoon
freeboard tracking charts; and 'the of
-P,
'-N
ANN&V
R
purchase
I I utilization
additional equipment to maximize utili ation of
our sprayfields and avoid land application
gg vl��
M
ME-
under marginal or unsuitable conditions.
H-
62
5-0 2
­ � — . -- 1. — --
g� W
Brown's EMS, which will be ISO 14000
certified by the end of 2001, will also
V, M
MWERN-2F4&r�
contribute to improved freeboard and land
application management.
Also Installed solid set irrigation system to
NOM
- W.
-2�
I N
increase available times to receive applications
pp
of smaller volume.
EzS-&-M mom
Pre -irrigation checklist is implemented
Communication improved between OIC and
office
US
Leased adjoining 180 acres of land to increase
wettable acres available for 2001 crop year
Concerns are based upon DWQ records consisting of deficiencies noted in state inspection reports, NOVs, penalty assessments and/or reports submitted to DWQ by the farm. Carefully
review your records to identify the specific concern or concerns and then describe the concern under the appropriate heading together with a reference to the specific record and the date of
El

the record (i.e., inspection report dated or NOV dated___). With the exception of "discharges," which cover calendar year 2000, concerns are based on DWQ records for the
calendar years beginning January 1, 1996, and ending December 31, 2000.
` Describe in as much detail as possible how the concern has been addressed, or, if it has not been addressed, the measures the farm intends to undertake to address the concern and a
schedule for completing the measures.
3 If subsurface drains are present, state whether you know that the drain(s) is discharging groundwater uncontaminated by hog waste, and if so, the basis for that conclusion.
5

Facility Number and Name: Brown's 9-155, Farm #28 (on original list)
Discharge(s)
High Freeboards-
Wettahle=Acres,
Description of Concern
INSPECTIONS
I/28/9S NOV for< l9" freeboard
/18/99-5122/99<19"
No discharges to surface waters in 2000
11/29199— 18— 1213199=>19"�
Re'.
2/2'00 — EPOA 117100 — 12,.P.
a"�`S"'.C,.
.s3r�^a'.s%3,�kM�,.� n- x..
21 5100 = i,��
i s 2125/00 = 16"
,a��i,,,,� � p � � T
3!24i00 - 18" 4/27/00 - POA
512100 = 16" 5/8x00 = > 19"
6/16'00-17" 6126x00 =IT'
7/13100 - > 19" Rl4100 = 18" POA
-�Axste
R/ 15100 = 18" POA 8,1[6100 = >19"
911!00 = 16" POA 916100 = 14""��F�a�;�
` -�, "' t` s
ME g
9120/00 = 14" 9125!00 = 14"
9/27/00 = Detail POA = 17"
sus r� ata�w$�
1013/00
1014(00 =>19" INSPECTION - l i/A'99 Freeboard Inadequate

rF.iak vy% "'.'"'-
. ate. - _ �_
Discharge(s) e(s
-
High Freeboards__
.,Sxs3'€.'yx 5a.«"'.-.. -�-1•-�
Y
42kA:t
v4 e e Acre
Response"
Due to excessive amounts of rainfall from hurricanes Dennis
- g21 M
g Floyd and efforts to prevent discharges, the additional
water was stored in the lagoon until more favorable weather
c aL�
•aria
�'�f '
conditions permitted land application. This caused the liquid
level in the lagoon to be significantly higher than normal
tom',$71
operation levels through following winter months. Since
kl
Hurricanes Dennis and Floyd, Brown's has implemented a
number of measures designed to minimize the potential for
rXy��
w
`�_.
future freeboard exceedances and over application during
prolonged or severe wet weather conditions- These measures
>�
include water conservation, which has reduced Brown's totaE
�.
annual water consumption by approximately 40 percent;
M s ':
hiring new employees; enhanced training; lagoon freeboard
tracking charts; and the purchase of additional equipment to
maximize utilization of ours ra fields and avoid land
ARM K - £
�
application under marginal or unsuitable conditions. Brown's
.."-
EMS, which will be ISO 14000 certified by the end of 2001
will also contribute to improved freeboard and land
RwKt
�V
application management-
Also, leased adjoining 180 acres of land to increase wettablePip
Z'
acres available for 2001 crop year.
Installed solid -set irrigation system to pem-iit a reduced rate
k
of application as well as a reduction in the total application
amount per application period and minimize potential for
runoff Installed summer 2000. Installed pressure gages on
rises winter 2000-
�r_-+ems•-.

Facility Number and Name: Brown's 9-155, Farm #28 (on original list)
X.
W
M�
MY
R �2,
loam
qbsdvrqM� imw-
Over ApLlication
42/9/99-
Structural Issues
0
r,
40i
Description of Concern
MINE saiwal M
3/10/97 NOV for runoff
3/24/9 7 - NRE for runoff
erosion noted on dike
-
W 'al
Q% X -M -MC
=111-wno
-'-W
8121/00 NOV/RE f
or overapplication
i�tk mom
ME
IS gr
fa=--
of PAN
819/00 Overapplication of PAN
gg
061. -"w,''^'"' -
OR

,:y .si"A•`-y...tiymt: ,� '�.�.?,; ,,� F.
YY1 ^-"iy', * ,.3�oM-���^','L.�{' •iY,✓vl'S'i6
Over Ap licatto
Structural IssuesCr_.o
1Y n �-°trnk f3F '.-t'"�^+ �Tpy�
,y=
..;En _Isuesu�.-
Response
� p ";F
*�
Due to excessive amounts of rainfall from
Dike was raised to correct low spots
��a &- ��-�"�x �r � - � R
�"�- _
2 Pam_ � <" —
h"``� _y •`'v'..r�'-0'�„�yYr'-cis •�''x'.m.' i--+.-?
�� s �,,
r
Hurricanes Dennis & Floyd and efforts to
tr
prevent discharges, the additional water was
due to long term settlement and
���� r
_ , - _•
�..7� '�a— ♦ --`� y-: ..a._..._v
��' gn
ryx
5 -_
�E�
�� � � {_
�.,�
applied to the land soil conditions were
suitable: in order to manage ieeboard levels,
minor erosion.
11/4/99 8/9/00 and 11/13)/00 DWQ
f x -
��� a� a
.y,
' PZ �
'er cst
c�
land application was accomplished during a
time period when crop uptake had already been
and Soil & Water inspections
indicated that no structures needed
;,
,
r?
51.
vtu,�
r �-
met. Since Hurricanes Dennis and Flotid,_T�.�,
additional maintenance or
r =
g
y s '�
sOO_:;x� h g
' ` F a d
Brown's has implemented a number of
measures designed to minimize the potential�;
for future freeboard exceedances and over
improvement.
June 2001 bare areas on dike
r _ t
6 �� .. ,��
aMlm,C i5?r 3S
.5
application during prolonged or severe wet
These measures include
reseeded.
4.
4 1.s'et XY. w•- ?r: 0
q�
weather conditions"
water conservation, which has reducedLBrown's
EN-31-
A-YL. �
k-
�� z ��
total annual water consumption by
a roximatel 40 ercent• hirin new
approximately P g
"
�­tL
_��`
c�� ��g
.}� � l�� a� rii.G j��.5c'SYS-Y.}
•¢i•-- �i,'Y.F` SZ TF: ✓s .,i^ -"'qe �',^�' 'AS "1�'Y'S
employees; enhanced training- lagoon
y g
freeboard tracking charts; and the purchase of
a "
R'F'
'13�'�'- �x
�R �N
MEAN " �`
to maximize utilization
M�w r
d
=
�� �:—
�
additional equipment of
land
r �•
9Og­ � -
� ,"
3�
our sprayf-telds and avoid application
under marginal or unsuitable conditions.
Brown's EMS, which will be ISO 14000
certified by the end of 2001, will also
xk��;k@
F OF
to improved freeboard land
_-
m
=•F
�- Napplication
t ��EW
�
contribute and
management.
Also Installed irrigation
fi
gr
x _ - z
--
tea' '
solid set system to
increase available times to receive applications
�
�
of smaller volume.
x �f
M1.fl.'F-a�yy-"!t
�.R-_ _'�i"-.�'?
^Y Rio :. }"
Pre -irrigation checklist' implemented
r s x .y
Y"��...E s''•.
-Pik X vi�'} G
„
Communication improved between OIC and
�T�+_
��'��aw K
* '��..,[�,.'i'r .'tltL ryLT}Ct„..ccf��E,�,�
otSl\.e
�`.t 7e.•T�-r-M^. TS'SY' r .3".S
««�C
g gm
>st �; y" . ✓�,1k ?.A.� -� �--e��y�y P
Leased adjoining 180 acres of land to increase
X ?
g �- '� � �i �t �'a`� d1 - �� �YY
wettable acres available for 2001 crop year
t Concerns are based upon DWQ records consisting of deficiencies noted in state inspection reports, NOVs, penalty assessments and/or reports submitted to DWQ by the farm. Carefully
review your records to identify the specific concern or concerns and then describe the concern under the appropriate heading together with a reference to the specific record and the date of
4

the record (i.e., inspection report dated or NOV dated _ _). With the exception of "discharges," which cover calendar year 2000, concerns are based on DWQ records for the
calendar years beginning January 1, 1996, and ending December 31, 2000.
z Describe in as much detail as possible how the concern has been addressed, or, if it has not been addressed, the measures the farm intends to undertake to address the concern and a
schedule for completing the treasures.
3 if subsurface drains are present, state whether you know that the drain(s) is discharging groundwater uncontaminated by hog waste, and if so, the basis for that conclusion.

MOORE
AND MAYNA14D
ATTORNEYS AT LAW
CCA/RTHOVSE DRIVE
EI.ILAUETHTOWN. N. C.
28331
a o� 348 PIU642
STATE OF NORTH CAROLINA
COUN'T'Y OF f3LAD EN WARRANTY DEED
THIS WARRANTY DEED made this the 14th day of October, 1994, by and
between the following: DALLAS McQUEEN CAMPBELL, III, single,
hereinafter referred to as Grantor to BROWN'S OF CAROLINA, INC.,
hereinafter referred to as Grantee.
W I T N E S S E T H:
That the Grantor, for and in consideration of the sum of TEN
($10.00) DOLLARS, and other good and valuable considerations to them in
hand paid by the Grantee, the receipt whereof is hereby acknowledged,
have given, granted, bargained, sold and conveyed, and by these presents
do give, grant, bargain, sell, convey and confirm unto the Grantee,
their heirs and/or successors and assigns, premises in Whites Creek
Township, Bladen County, North Carolina, and more particularly described
as follows:
Those certain lands containing 254.40 acres, more or
less, as shown on Survey for Mrs. Margaret Clark,
prepared December 12, 1988, by Stuart Gooden, Registered
Surveyor, and recorded in Plat Cabinet A--81, Page 812, in
the Office of the Register of Deeds of Bladen County,
which recorded map is made a part hereof by reference for
greater certainty of description.
Subject to right of way for Seaboard Coastline Railroad,
N.C. highway 211 and power line right of way to Carolina
Power and Light Company as shown on the aforesaid survey.
TO HAVE AND TO HOLD the above described premises, with all the
appurtenances thereunto belonging, or in any wise appertaining, unto the
Grantee, their heirs and/or successors and assigns in fee simple
forever.
And the Grantor covenant that they are seized of said premises in
fee, and have the right to convey the same in fee simple; that said
premises are free from encumbrances; and that they will warrant and
defend the title to the same against the lawful claims of all persons
whclnsoeve r .
IN WITNESS WHEREOF, the Grantor has hereunto set his hand and seal,
the day and year first above written.
(SEAL)
DALLAS M QUgN , III
Prepared by: Alan I. Maynard
sir � A�u� �� /Y. �' i

eoa 348 PAcI643
STATE OF NORTH CAROLINA
COUNTY Or BI -ADEN
I, T.VI; la kY U , a Notary Public of said County, do
hereby certify that DALLAS McQUEEN CAMPBELL, III, personally appeared
before me this day and acknowledged the due execution of the foregoing
instrument for the purposes therein described.
my �.f 4 • day of
Witness hand and notarial seal, this the
1994.
NOTARY PUBLIC
My Ccnrnission expires:
I 7 -3.91
STATE OF NORM CAROLINA
COUNTY OF SLADEN
The foregoing certificate of -Ll, a Notary
Public of North Carolina, is certified to be correct. This instrument
was presented for registration this day of , 1994,
at � o'clock -Y 2:11M.,
M., and duly recorded in this Office of the
Register of Deeds of Bladen County, North Carolina, in Book,:U2, Page
}ZEGISTER OF DEEDS
RDGISTER OF DEEDS
J4
00�
1
1;
•M

t .!I
i.4.
994 4 l?
n

v „

z
~ ;
S

;._
_ '.
:: ' .
- ; , , s ,#c Y
_rr j. - .
t14
- ss L _kk - _
+ 1\S _

ckl
444
/00T
•

4�
�1
1
4�
1

I �
v
// / • _ � - {tea._-cv-` _
1 t
// / • _ � - {tea._-cv-` _

d�

Al.
-

"" 1 P
t.
•A
p ,, . ��
��

'h Ate\
n� ti'
��r
ye
7
'r c _
ilk- ,a�� �\:
-
1, " '
�-
�,.!
_ ��.
p^ 7s
�, �
�_
�c � , 'ti i 'R •.Y

;w:.
,� c
x �
•,�•� yea.. �
w
n 'C` ''r "� -�
`�� .
�. � ;,y � `
_�
..� � .:.
~.'�

�'i

0
fir �1-
+fit i y ?g

100 c? 25

?�7O 9 25