090082_CORRESPONDENCE_20171231

PLAN OF ACTION (PoA) FOR HIGH FREEBOARD AT ANIMAL FACILITIES
Facility Number: - ;� County: 81 oJen
Facility Name: e ven 4b
Certified Operator Name:
Operator #
1. Current liquid level(s) in inches as measured from the current liquid level in the lagoon to the
lowest point on the top of the dam for lagoons without spillways; and from the current liquid level
in the lagoon to the bottom of the spillway for lagoons with spillways_
Structure 1 Structure 2 Structure 3 Structure 4 Structure 5 Structure B
Lagoon Name/Identifier (ID): 1
Spillway (Yes or No):
Level (inches):
2. Check all applicable items
1-0
llL
Liquid level is within the designed structural freeboard elevations of one or more structures. Five
and 30 day Plans of Action are attached. Hydraulic and agronomic balances are within
acceptable ranges.
V Liquid level is within the 25 year 24 hour storm elevations for one or more structures. A 30 day
Plan of Action is attached. Agronomic balance is within acceptable range.
Waste is to be pumped and hauled to off site locations. Volume and PAN content of waste to
pumped and hauled is reflected in section III tables. Included- within this plan is a list of the
proposed sites with related facility number(s), number acres and receiving crop information.
Contact and secure approval from the Division of Water Quality prior to transfer of waste
to a site not covered in the facility's certified animal waste management plan.
Operation will be partially or fully depopulated.
- attach a complete schedule with corresponding animal units and dates for depopulation
- if animals are to be moved to another permitted facility, provide facility number, lagoon
freeboard levels and herd population for the receiving facility
3. Earliest possible date to begin land application of waste: q 11-71 1$
I hereby certify that I have reviewed the information listed above and included within the attached Plan
of Action, and to the best of my knowledge and ability, the information is accurate and correct.
�eveYl smite
Facility Owner/Manager (print)
Facility Owner/Manager (signature)
PoA Cover Page 2121100
Phone: I iy - -770 ' v539
Date: �-Dt - V

10
II. TOTAL POUNDS OF PAN STORED WITHIN STRUCTURAL FREEBOARD ANDIOR 25 YRJ24
HR. STORM STORAGE ELEVATIONS IN ALL WASTE STRUCTURES FOR FACILITY
1. Structure ID: 1
2. Structure ID:
3. Structure ID:
4. Structure ID:
5. Structure ID:
6. Structure ID:
line m = 1966.8 lb PAN
line m = lb PAN
line m = lb PAN
line m = lb PAN
line m = lb PAN
line m = lb PAN
n.lines 1+2+3+4+5+6= 1966.8lbPAN
III. TOTAL PAN BALANCE REMAINING FOR AVAILABLE CROPS DURING 30 DAY DRAW DOWN
PERIOD. DO NOT LIST FIELDS TO WHICH PAN CANNOT BE APPLIED DURING THIS 30 DAY PERIOD.
o. tract #
p. field #
q. crop
r. acres
s. remaining IRR
2 PAN balance
(Ib/acre)
t TOTAL PAN
BALANCE FOR
FIELD (lbs.)
column r x s
u. application window'
2589
1
wheat
10.00
144.00
1440.0
Oct -Mar
2589
2
wheat
12.00
144.00
1728.0
Oct -Mar
2589
3
wheat
20.00
144.00
2880.0
Oct -Mar
'State current crop ending application date or next crop application beginning date for available
receiving crops during 30 day draw down period.
v. Total PAN available for all fields (sum of column t) = 6048.0 lb. PAN
IV. FACILITY'S PoA OVERALL PAN BALANCE
w. Total PAN to be land applied (line n from section 11) = 1966.8 lb. PAN
x. Crop's remaining PAN balance (line v from section III) = 6048.0 lb. PAN
y. Overall PAN balance (w - x) = -4081 lb. PAN
Line y must show as a deficit. if line y does not show as a deficit, list course of action here including pump and
haul, depopulation, herd reduction, etc. For pump S haul and herd reduction options, recalculate new PAN
'based on new information. If new fields are to be included as an option for lowering lagoon level, add these
fields to the PAN balance table and recalculate the overall PAN balance. If animal waste is to be hauled to
another permitted facility, provide information regarding the herd population and lagoon freeboard levels at the
receiving facility.
NARRATIVE:
Will begin pumping as soon as field conditions allow.
PoA (30 Day) 2/21/00

PLAN OF ACTION (PoA) FOR HIGH FREEBOARD AT ANIMAL FACILITIES
30 DAY DRAW DOWN PERIOD
I. TOTAL PAN TO BE LAND APPLIED PER WASTE STRUCTURE
1. Structure Name/ldentifier (ID): 11
2. Current liquid volume in 25 yr./24 hr. storm storage 8, structural freeboard
a. current liquid level according to marker 14.0 inches
b. designed 25 yr./24 hr. storm $ structural freeboard 19.0 inches
c. line b - line a (inches in red zone) = 5.0 inches
d. top of dike surface area according to design
(area at below structural freeboard elevation) 331235 fe
e. line c/12 x line d x 7.48 gallons/fe 1032349 gallons
3. Projected volume of waste liquid produced during draw down period
f. temporary storage period according to structural design 180 days
g. volume of waste produced according to structural design 80306 ft3
h. current herd # 2448 certified herd #1 2448
actual waste produced = current herd # x line g =
certified herd #
i. volume of wash water according to structural design
j. excess rainfall over evaporation according to design
k. (lines h + i + j) x 7.48 x 30 days/fine f=
4. Total PAN to be land applied during draw down period
I. current waste analysis dated 1 8/31/2018
m. ((lines e + k)/1000) x line I
REPEAT SECTION I FOR EACH WASTE STRUCTURE ON SITE.
(Click on the next Structure tab shown below)
80306 W
ft3
ft3
42000 ft3
152475 gallons
1.66 11bs/1000 gal.
1966.8 lbs. PAN
PoA (30 Day) 2/21/00

1
v-
PLAN OF ACTION (PoA) FOR HIGH FREEBOARD AT ANIMAL FACILITIES
Facility Number: 1 - q I County: 1 lie
Facility Name:
Certified Operator Name: NI Ian _ Operator #
1. Current liquid level(s) in inches as measured from the current liquid level in the lagoon to the
lowest point on the top of the dam for lagoons without spillways; and from the current liquid level
in the lagoon to the bottom of the spillway for lagoons with spillways.
Structure 1 Structure 2 Structure 3 Structure 4 Structure 5 Structure 6
Lagoon Namelidentifier (ID)
Spillway (Yes or No):
Level (inches):
2. Check all applicable items
V Liquid le designed structural freeboard elevations of one or more structures. Five
an 0 day Plans of Action a attach d. Hydraulic and agronomic balances are within
accep a e ranges. L w S4exr- � ,
Liquid level is within the 25 year 24 hour storm elevations for one or more structures. A 30 day
Plan of Action is attached. Agronomic balance is within acceptable range.
Waste is to be pumped and hauled to off site locations. Volume and PAN content of waste to
pumped and hauled is reflected in section III tables. Included within this plan is a list of the
proposed sites with related facility number(s), number acres and receiving crop information.
Contact and secure approval from the Division of Water Resources prior to transfer of
waste to a site not covered in the facility's certified animal waste management plan.
Operation will be partially or fully depopulated.
- attach a complete schedule with corresponding animal units and dates for depopulation
- if animals are to be moved to another permitted facility, provide facility number, lagoon
freeboard levels and herd population for the receiving facility
3. Earliest possible date to begin land application of waste:
I hereby certify that I have reviewed the information listed above and included within the attached Plan
of Action, and to the best of my knowledge and ability, the information is accurate and correct.
-C r
Owner/Manager (print)
Facility Owner/Manager (signature)
Phone: 916- rx- SLog"I
Date: Z /�
PoA Cover Page 2121100

PLAN OF ACTION (PoA) FOR HIGH FREEBOARD AT ANIMAL FACILITIES
30 DAY DRAW DOWN PERIOD
I. TOTAL PAN TO BE LAND APPLIED PER WASTE STRUCTURE
1. Structure Namelldentifier (ID): 1
2. Current liquid volume in 25 yr./24 hr. storm storage & structural freeboard
a. current liquid level according to marker 5.0 inches
b. designed 25 yr./24 hr. storm & structural freeboard 19.0 inches
c. line b - line a (inches in red zone) = 14.0 inches
�_
d. top of dike surface area according to design
(area at below structural freeboard elevation) 49875 fe
e, line c/12 x line d x 7.48 gallons/fe 435243 gallons
3. Projected volume of waste liquid produced during draw down period
f. temporary storage period according to structural design 180 days
g. volume of waste produced according to structural design 58023 ft3
h. current herd # 1760 certified herd #1 1760
actual waste produced = current herd # x line g =
certified herd #
i. volume of wash water according to structural design
j. excess rainfall over evaporation according to design
k. (lines h + i + j) x 7.48 x 30 days/line f=
4. Total PAN to be land applied during draw down period
I. current waste analysis dated 1 9/11/2018
m. ((fines e + k)/1000) x line I
REPEAT SECTION I FOR EACH WASTE STRUCTURE ON SITE.
(Click on the next Structure tab shown below)
58023 ft'
ft3
29093.8 ft3
108606 gallons
0.94 Ibs/1000 gal.
511.2 lbs. PAN
PoA (30 Day) 2/21100

.y
II. TOTAL POUNDS OF PAN STORED WITHIN STRUCTURAL FREEBOARD AND/OR 25 YRJ24
HR. STORM STORAGE ELEVATIONS IN ALL WASTE STRUCTURES FOR FACILITY
1.
Structure ID: 1
line m =
511.2 lb PAN
2.
Structure ID:
line m =
lb PAN
3.
Structure ID:
line m =
lb PAN
4.
Structure ID:
line m =
lb PAN
5.
Structure ID:
line m =
lb PAN
6.
Structure ID:
line m =
lb PAN
n.lines 1+2+3+4+5+6= 511.2lbPAN
III. TOTAL PAN BALANCE REMAINING FOR AVAILABLE CROPS DURING 30 DAY DRAW DOWN
PERIOD. DO NOT LIST FIELDS TO WHICH PAN CANNOT BE APPLIED DURING THIS 30 DAY PERIOD.
o. tract #
p. field #
q. crop
r. acres
s. remaining IRR
2 PAN balance
(lb/acre)
t TOTAL PAN
BALANCE FOR
FIELD (Ibs.)
extumn r x s
u. application window
4628
1AC
small grain
4.30
50.00
215.0
Oct -Mar
4628
1 B
small grain
3.20
50.00
160.0
Oct -Mar
4628
2
small grain
1.70
50.00
85.0
Oct -Mar
4628
3
small grain
0.75
50.00
37.5
Oct -Mar
4628
1AC
bermuda
4.30
25.00
107.5
Mar -Oct
'State current crop ending application date or next crop application beginning date for available
receiving crops during 30 day draw down period.
v. Total PAN available for all fields (sum of column t) = 605.0 lb. PAN
IV. FACILITY'S PoA OVERALL PAN BALANCE
w. Total PAN to be land applied (line n from section 11) = 511.2 lb. PAN
x. Crop's remaining PAN balance (line v from section III) = 605.0 Ib. PAN
y. Overall PAN balance (w - x) = -94 Ib. PAN
Line y must show as a deficit. If line y does not show as a deficit, list course of action here including pump and
haul, depopulation, herd reduction, etc. For pump & haul and herd reduction options, recalculate new PAN
based on new information. If new fields are to be included as an option for lowering lagoon level, add these
fields to the PAN balance table and recalculate the overall PAN balance. If animal waste is to be hauled to
another permitted facility, provide information regarding the herd population and lagoon freeboard levels at the
receiving facility.
NARRATIVE:
will begin pumping as soon as field conditions permit.
PoA (30 Day) 2/21/00

_ Site Requires Immediate Attention:
r
'r Facility No- '
DIVISION OF ENVIRONMENTAL MANAGEMENT
ANAL FEEDLOT OPERATIONS SITE VISITATION RECO IM
DATE: 3 , 1995
Time: 3.
Farm Name/Owner:
Mailing Address: F_tnq -
County: I.
Integrator: Phone:C/d) d �1�_ y � On Site Representative: )3e � A, lh, a N Phone: zyw _
Physical Address/Location: _
Type of Operation: Swine Poultry Cattle
Design Capacity: Number of Animals on Site: _2- J4,y zEtz,ds�_
DEM Certification Number: ACE ^ DEM Certification Number: ACNEW
Latitude: Longitude: "
Circle Yes or No
Does the Animal Waste Lagoon h sufficient freeboard of 1 Foot + 25 year 24 hour storm event
(approximately 1 Foot + 7 inches) or No Actual Freeboard:_.5' Ft. Inches
Was any seepage observed from the lagoon(s)? Yes or Was any erosion observed? Yes or No
Is adequate land available for spray? e or No Is the cover crop adequate? Yes or No
Crop(s) being utilized: �+ C�
Does the facility meet SCS minimum setback criteria. 200 Feet from Dwellings? a or No
100 Feet from Wells? es or,o
Is the animal waste stockpiled within 100 Feet of USGS Blue Line Stream? Yes or
Is animal waste land applied or spray irrigated within 25 Feet of a USGS Map Blue Line: Yes ore
Is animal waste discharged into water of a state by man-made ditch, flushing system, or other
similar man-made devices? Yes or o If Yes, Please Explain.
Does the facility maintain adequate waste management rectos (volumes of manure, land applied,
spray irrigated on specific acreage with cover crop)? Q or No
Additional Comments:
Inspector Name
ore_"�
Signature
FO-
cc: Facility Assessment Unit Use Attachments if Needed.

racuuy Number: - -
Division of Environmental Management
Animal Feedlot Operations Site Visitation Record
Date: &7
Time: 3
General Informalon:
Farm Name: L�, be-_ County: 61c, dew
Owner Nam: v r S rr;- No: 6q9 —
On Site Representative: a 13" integrator. ur
Making Address: R'; L4 (� G x (a g 3
r,, - C v $ 3Z.C>
Physical Address/Location•
Latitnde•_1 / Lon 'tude:_/ /
eration Desc • (based on design characteristics)
7jpe of Swine No. of Animals Type of Poultry No. of AMMU Type of Cask No. of Animals
0 Sow Mayer C Daay
CO Nmsety O Non -Layer O Baef
D Feeder _
OtherType of LivesmerE in Number ofAnimals:
Number of Lagoons: OocludeJ the Drawings and Observations tbo freeboard of each lagoon)
Factlily I
Lagoon
Is lagoon(s) freeboard less than 1•foot + 25 year 24 hour storm storage?:
Yes ❑
Nam --
Is seepage observed from the. lagoon?:
Yes ❑
No-E�
Is erosion observed?:
Yes ❑
NoZP
Is any discharge observed?
Yes ❑
NAP
Q Man-made Q Not Macs -made
Cover Crop
Does the facility need more acreage for spraying?:
Yes 0
NAP
Does the cover crop need improvem=0:
Yes D
. Now
(list the crops which need improwment)
CM type: f �C- A f-� -'_,e Q,1, ._ :
Setback Crilerfa '
Is a dwelling located within 200 feet of waste application?
Yes O
N
Is a well located within 100 feet of waste application?
Yes 1
Na
Is animal waste stockpiled within 100 feet of USGS Blue Line Stream?
Yes.O
No
'Is animal waste land applied of spray irrigated within 25 feet of Blue Line Stream?
Yes ❑
No,,(
AOI — ]annoy 17JM

, Maiwenance
Does the facility maintenance need improvement? Yes 0 No
Is there evidence of past discharge from any part of the operation? Yes 0 Nop
F Does record keeping need improvement? Yes ❑ No)2f
Did the facility fail to have a copy of the Animal Waste Management Plan on site? Yea ❑ No 0
Explain any Yes answew;
signanzre: Dane: 9b
= F4airy Asses msw Ujiit Uu Anachrnents ¢Xeedcd
)2rawinas _Qr_ QbsgMdQDE
Fret y 0 &— � = a -F— fi'
_ t70ti Lokr 6 COr-A- of o l"
111,.;,� t 6 l� �enfS
) �-ss CO rre.r` 0 A
• ... - � nnlrn'ry.--.n r. ��+e-�.. •saf uy. SY' 1►�rr�MR -r�sara�.K a• 1!-� =,
• aY �-�«�....Lw �4'r •r -� 4,.p� ►�i:► �:. •1.y ��.rr!!��Iw�..� I. �=- .. ...
AOI — Januw T 17,19%

State of North Carolina
Department of Environment,
Health and Natural Resources
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
November 13, 1996
Murphy Smith
Double S Farm
Rt 4 Box 683
Bladenboro NC 28320
SUBJECT: Operator In Charge Designation
Facility: Double S Farm
Facility ID#: 9-82
Bladen County
Dear Mr. Smith:
�C�ai��'
NOV 19 1996
FAY 37-
F1F;
Senate Bill 1217, An Act to Implement Recommendations of the Blue Ribbon Study
Commission on Agricultural Waste, enacted by the 1996 North Carolina General Assembly,
requires a certified operator for each animal waste management system that serves 250 or more
swine by January 1, 1997. The owner of each animal waste management system must submit a
designation form to the Technical Assistance and Certification Group which designates an
Operator in Charge 'and is countersigned by the certified operator. The enclosed form must be
submitted by January 1, 1997 for all facilities in operation as of that date. Failure to designate a
certified operator for your animal waste management system is a violation of 15A NCAC 2H
.0224 and may result in the assessment of a civil penalty.
If you have questions concerning operator training or examinations for certification, please
contact your local North Carolina Cooperative Extension Service agent or our office.
Examinations have been offered on an on -going basis in many counties throughout the state for
the past several months and will continue to be offered through December 31, 1996.
Thank you for your cooperation. If you have any questions concerning this requirement please
call Beth Buffington or Barry Huneycutt of our staff at 919/733-0026.
Sincerely,
i Ir
r j
_j
A. Preston Howard, Jr., P.E., Director
Division of Water Quality
Enclosure
cc: Fayetteville Regional Office
Water Quality Files
P.O. Box 27687, FAX [phone]
Raleigh, North Carolina 27671-7687 % 4)An Equal Opportunity/Affirmative Action Employer
Voice 919-715-4100 50% recycled/10% post -consumer paper

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B_ Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
Double S Farm
19829 Hwy 131 S.
Bladenboro NC 28320
Attn: Murphy Smith
Dear Murphy Smith:
Y?, V
IT 0 0
A&4
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND Ift
ECM V CD
February 9, 1999 piles
FE B 10 1999
FAYETTEVI!LLE
REG. OFFICE
Subject: Application No. AWS090082
Additional Information Request
Double S Farm
Animal Waste Operation
Bladen County
The Non -Discharge Permitting Unit has completed a preliminary engineering review of the subject application. Additional
information is required before we can continue our review. Please address the following by March 11, 1999:
Please provide lagoon capacity documentation (design, as -built calculations, etc.). Be sure to include any
site evaluations, wetland determinations, or hazard classifications that may be applicable.
Please also provide an Operation and Maintenance Plan for this facility. Be sure to keep a copy with your
files at the facility.
Please reference the subject permit application number when providing the requested information_ All information should be
signed, sealed, and submitted in duplicate to my attention at the address below. The information requested by this letter
must be submitted on or before March 11, 1999 or the Division will return your application as incomplete in accordance with
15A N.C.A.C. 2H .0200 and your facility will be considered to be operating without a permit.
Please be advised that operation of the subject animal waste management system without a valid permit is a violation of
North Carolina General Statute 143-215.1 and will subject you to the enforcement authority of the Environmental
Management Commission.
If you have any questions regarding this request, please call me at [phone], extension 364_
Sincerely,
WNI"�
Dianne Thomas
Soil Scientist
Non -Discharge Permitting Unit
cc:etteville RegionaI'Office Water Quality
Per`mif File
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
Murphy Smith
Double S Farm
19829 Hwy 131 South
Bladenboro NC 28320
Dear Murphy Smith:
•ffl?W'A/
NCDENR
NORTH CAROUNA DEPARTMENT OF
ENVIRONMENT ANt] N,rrURAL RESOURCES
December.30, 1999
RECEIVED
J AN 10 2000
FAYETTEVILLE
REG. C:"iiCE
Subject: Fertilizer Application Recordkeeping
Animal Waste Management System
Facility Number 9-82
Bladen County
This letter is being sent to clarify the recordkeeping requirement for Plant Available Nitrogen (PAN)
application on fields that are part of your Certified Animal Waste Management Plan.
In order to show that the agronomic loading rates for the crops being grown are not being exceeded, you
must keep records of all sources of nitrogen that are being added to these sites. This would include nitrogen
from all types of animal waste as well as municipal and industrial sludgestresiduals, and commercial fertilizers.
Beginning January 1, 2000, all nitrogen sources applied to land receiving animal waste are required to
be kept on the appropriate recordkeeping forms (i.e. IRR1, IRR2, DRY1, DRY2, DRY3, SLUR1, SLUR2,
SLD1, and SLD2) and maintained in the facility records for review. The Division of Water Quality (DWQ)
compliance inspectors and Division of Soil and Water operation reviewers will review all recordkeeping during
routine inspections. Facilities not documenting all sources of nitrogen application will be subject to an
appropriate enforcement action.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Ms. Sonya Avant of the
DWQ staff at [phone] ext. 571.
Sincerely,
Kerr T. Stevens, Director
Division of Water Quality
cc: Fayetteville Regional Office
Bladen County Soil and Water Conservation District
Facility File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

State of North Carolina
Department of Environment
and Natural Resources
Michael F. Easley, Governor
William G. Ross Jr., Secretary
Kerr T. Stevens, Director
June 4, 2001
CERT97IIED MAIL
RETURN RECEIPT REQUESTED
Murphy Smith
Double S Farm
19829 Hwy 131 South
Bladenboro NC 28320
,Tk?WAA
IT
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Notification for Wettable Acre Determination
Animal Waste Management System
Double S Farm
Facility Number 9-82
Bladen County
Dear Murphy Smith:
A letter dated January 15, 1999 was sent to advise you about concerns associated with Certified Animal
Waste Management Plans and the method by which the irrigated acres within the plans were calculated. Only
the acres that are wetted can be credited in the waste management plan as receiving waste application. Any
acreage within the plan that can not be reached by waste application equipment can not be used as part of your
plan.
An evaluation by Audrey Oxendine on 6/9/99 was made to review the actual number of acres at your
facility that receive animal waste during land application. The evaluation of your facility has yielded one of
the following two results as indicated by the box marked with an "X".
Category 1:
The evaluation of your facility could not be completed due to a lack of information. Please
contact your Technical _ Specialist to assist in providing Trent Allen the necessary
information to potentially exempt your facility from undergoing a complete wettable acre
determination. Please submit this information to Trent Allen, at 225 Green Street, Suite
714, Fayetteville, NC 28301, within in 90 days of the receipt of this letter. If you have any
questions please contact Trent Alien at [phone]. If within 90 days you are unable
to provide Trent Allen with the information you are automatically required to complete
a Wettable Acre Determination as described by Category 2 below, within 180 days
of receipt of this letter.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recvcled/10% post -consumer paper

Notification for Wettable Acre Determination
Animal Waste Management System
Page 2
Category 2:
❑ Your facility has been identified by the Department of Environment and Natural Resources
as a facility that may have overestimated the number of acres actually receiving animal
waste. Therefore, some or all of your fields may be exceeding the allowable loading rates
set in your Certified Animal Waste Management Plan.
In order to resolve this issue, please contact a designated Technical Specialist to have him
or her conduct a Wettable Acre Determination for your facility. The Technical Specialist must
be one that has been approved by the Soil and Water Conservation Commission to conduct
Wettable Acre Determinations. Many Technical Specialist with the N.C. Cooperative Extension
Service, the Soil and Water Conservation Districts, the Natural Resources Conservation
Service, and the Division of Soil and Water Conservation have received this special
designation. You may also contact a private Technical Specialist who has received this
designation, or a Professional Engineer.
All needed modifications to your Animal Waste Management System must be made and
the Wettable Acres Determination Certification must be returned to DWO within the next
180 days. If the needed modifications are not made and if the form is not returned within the
required time, DWQ will be forced to take appropriate enforcement actions to bring this facility
into compliance. These actions may include civil penalty assessments, permit revocation,
and/or injunctive relief.
Once a Wettable Acre Determination has been completed, a copy of the attached Wettable
Acre Determination Certification must be submitted to the address listed on the form. Please
note that both the owner and the Technical Specialist must sign the certification. A copy of all
the Wettable Acre Determination documentation that applies to your Waste Utilization Plan
must be kept at your facility. DWQ and the Division of Soil & Water Conservation Staff will
review all documentation during their annual visit of your facility. An additional copy must by
kept on file at the local Soil & Water Conservation District Office. Please note that if you install
or modify your irrigation system, a designated Irrigation Specialist or a Professional Engineer
must also sign the Wettable Acre Determination Certification.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Sonya Avant of our
Central Office staff at [phone] ext_ 571.
Sincerely,
Kerr T. Stevens
cc: FRO Regional Office
Bladen County Soil and Water Conservation District
Facility File
Murphy Family Farms

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
Michael F. Easley, Governor
William G. Ross Jr., Secretary
Kerr T. Stevens, Director
May 31, 2001
MEMORANDUM
To: Regional Water Quality Supervisor
N.C."F'A
IT 0 0
A&4 'V a
NCDENR
Nc)RTH CAROuNA DEPARTMENT of
ENVIRONMENT AND N.Z uRAL F E_-,ou 2cEs
From: Sonya Avant, Environmental Engineer AXa
Non -Discharge Compliance and Enforcement Unit
r-IJ
JUN f Q 2001
Subject: Wettable Acre Determinations for Certified and Permitted Operations
Attached is a list of the facilities in your respective regions that have been selected to receive
notification letters advising them that they have been flagged or pended for the month of June.
Each facility will be given written notice via certified mail. The notice will include a copy of the
certification forth and a deadline for response.
I will also be sending copies of the final monthly list of selected facilities to the Division of Soil
and Water Conservation Operation Reviewers and Soil Water Conservation District Offices each
month along with an updated copy of all facilities in that county that have been either flagged or
pended. This will hopefully enable the Districts to be better able to schedule their workloads.
If you have any questions, please contact the at 733-5083 extension 571, or
sonya.avant @ncmail.net.
cc: Coleen Sullins
1617 Mail 5errire Center, Raleigh. North Carolina 27699-1617 Telephone [phone] Fax 919-71=-6048
An Equal Opportunity AF6rfnatiye Action Employer 50% recycied/10% post -consumer paper

Facilities Flagged/Pended for June 1, 2001
Facility Flagged/Pending
Number Owner I Farm Name Address Status
WA PAN deficit WA Visit Date Integrator
FRO
09 — 82 Murphy Smith 19829 Hwy 131 South P1 2700 6/9/1999 Murphy Family Farms
Bladenboro NC 28320
Double Form
09 — 182 Tommy & Splawn 51156 Elizabethtown F2 1943 3/3/1999 Carroll's Foods Inc
Karen Highway
Crooked Branch Farm Roseboro NC 28382
82 — 2 Johnny Tyndall 3376 Howard Road F4 I1I4.40 5/3/1999 Murphy Family Farms
Autryville, NC 28319
Tyndall & Suns Farm
82 -.- 40 William Powell 484 Tomahawk Highway F4 945 6/17/1999 J&K Farms
. Harrells NC 28444
William Powell Farm N 3
82 — 48 Perry Smith 110 Box 68 F4 1154 V2211999 Carroll's Foods, Inc.
Turkey NC 28393
Perry Smith Farm
82 — 52 McLamh 382 Pig Cradle Lane F4 1281 4/13/1999 Murphy Family Farms
Corporation Clinton NC 28328
A.M. Farm
82 — 53 F & W Farms 1557 Andrews Chapel F4 1250,493 V2,VI"9 Carroll's Foods Inc
Road
....................................
F & W Farms / B - T Farm Rosehoro NC 28382

A
Facilities Flagged/Pended for June 1, 2001 1 �
Facility
Flagged/Pending
Number
Owner / Farm Name
Address
Status
WA PAN deficit WA Visit Date Integrator
82 — 62
Earl Benny King
1746 rowan Rd
P3
1224 6/22/1999 Dogwood Farms
Clinton NC 28328
Earl Benny King Farm
•
I
82 - 71
Gerald Warren
P.O. Box 233
F4
1004 6/14/1999 Warren Swine Farms
Newton Grove 28366
Gerald Warren Farm
82 89 George Thornton 1054 Sharecake Rd F4 1059 4/27/1999 Prestage Farms
Clinton NC 28328
George 'Thornton
82 — 99 Marshall Falatovich 410 Beaver Dam Drive F4 1291.2 4/21/1999 Prestage Farms
Clinton NC 28328
Falatovich Finishing #2
82 --101 Joe Rose 481 Lassiter Rd F4 1221.175 7/1/1999 TDM Farms, Inc.
Newton Grove 28366
Rose Swine Farms
H2 — 103 Sue & James Butler 10444 N US 421 Highway F4
H. Clinton NC 28328
Sue Butler Farm
914.9 4/27/19" Murphy Family Farms
82 — 107 David Iwtckamy 1045 Holleriu (toad 133 1181.4 5/12/1999 Murphy Family Farms
Dunn NC 28334
L&1, Farms
82 — 115 Robert Jackson 1494 Feed Mill Road F4 951 5/10/1999 Murphy Family Farms
, Rosehoro NC 28382
Across the Creek Farm
'f

Facilities Flagged/Pended for June 1, 2001
Facility Flagged/Pendm`g zr t
Number Owner / Farm Name Address Status WA PAN deficit ;; WA Visit Dale Integrator
82 — 171 Virgil Strickland 3500 Keener Rd. P3 1073.5 4/29/1999 Murphy Family Farms
Clinton NC 28328
Virgil Strickland Farm
82 — 179 Nelson & Butler 683 Odom Rd F2 981 5/11119" Prestage Farms
Jerry Clinton NC 28328
N&J Butler Pig Farm
82 — 246 Calvin Edwards PO Box 472 FI 897 V1011999 Murphy Family Farms
Rusehoro NC 28382
Calvin Edwards Farm
82 — 260 Ronnie Smith 999 Moseley Ave F4 974 3/22/1999 Murphy Family Farms
. Clinton NC 28328
B&K Nursery 1 & 2
82 — 601 Billy Ray Daughtry 1960 Roanoke Rd F4 1097 6C.i0/I999 TDM Farms, Inc.
Clinton NC 28328
Billy Ray Daughtry
82 — 620 Thomas Ray McPhail 11020 Dunn Rd PI 1004.45 5/13/1999 Prestage Farms
. Salcmhurg NC 28385
McPhail Nursery Farm
82 —653 Sleed Farms, Inc. 2311 Keener Road P2 954 5/4/1999 Murphy Family Farms
Clinton NC 28328
Thomas Sleed Farm #2
i

North Carolina
Department of Environment and Natural Resources
Water Pollution Control System Operator Certification Commission
Michael F. Easley, Governor
William G. Ross Jr., Secretary
Coleen H. Sullins, Chairman
February 21, 2001
Murphy Smith
19829 Hwy 131 South
Bladenboro NC 28320
SUBJECT: Designation of Operator in Charge
Farm Name: Double S Farm
Facility ID #: 09-82
County: Bladen
Dear Mr. Smith:
e��
NCDENR
,..�- :�,•Q � H � J� tSm i1J
MAR 2 7 2001
Senate Bill 1217, An Act to Implement Recommendations of the Blue Ribbon Study Commission on Agricultural
Waste, was enacted by the 1996 North Carolina General Assembly. This legislation requires owner of a certified
operator for each animal waste management system that serves 250 or more swine, 100 or more confined cattle,
75 or more horses, 1,000 or more sheep, or 30,000 or more confined poultry with a liquid waste management
system.
Our records indicate that the operator designated as the Operator In Charge (OIC) for your animal waste
management system is no longer certified. Therefore, you must designate a properly certified animal waste
management system operator as the OIC for your facility. The enclosed designation form must be returned to this
office by April 1, 2001. This office maintains a list of certified operators in your area if you need assistance in
locating a certified operator.
Failure to designate a properly certified Operator in Charge for your facility is a violation of N.C.G.S. 90A-47.2
and 15A NCAC 8F .0201(a) and may result in the initiation of enforcement action. Please be advised that nothing
in this letter should be taken as resolving you of the responsibility and liability for any past or future violations for
your failure to have a properly certified Operator in Charge designated for your animal waste management system.
If you have questions concerning this matter, or if this office can be of further assistance, please call Beth
Buffington at [phone], extension 313.
Sincerely,
Dwight Lancaster, Supervisor
Technical Assistance and Certification Unit
Enclosure
cc: TAC Files
Non -Discharge Compliance/Enforcement Unit
Fayetteville Regional Office
Central Files
1618 Mail Service Center, Raleigh, North Carolina 27699-1618
Phone: 919 — 733-0026 1 FAX: 919 — 733-1338
AN EQUAL OPPORTUNrrY 1 AFFIRMATIVE ACTION EMPLOYER - 50% RECYCLED / 10% POST CONSUMER PAPER

State of North Carolina
Department of Environment
and Natural Resources RECEIVED
of Water Quality R
.lames B. Hunt, Jr., Governor APR 6 1999
Wayne McDevitt, Secretary
Kerr T. Stevens, Director FAYE17EVILLE
REG. OFFICE
March 25, 1999
Double S Farm
19829 Hwy 131 S.
Bladenboro NC 28320
Attn: Murphy Smith
A M?W'A
IT 0 0
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Certificate of Coverage No. AWS090082
Double S Farm
Swine Waste Collection, Treatment,
Storage and Application System
Bladen County
Dear Murphy Smith:
In accordance with your application received on January 7, 1999, we are forwarding this Certificate of
Coverage (COC) issued to Murphy Smith, authorizing the operation of the subject animal waste
collection, treatment, storage and land application system in accordance with General Permit
AWG100000. This approval shall consist of the operation of this system including, but not limited to,
the management of animal waste from the Double S Farm, located in Bladen County, with an animal
capacity of no greater than 2448 Feeder to Finish and the application to land as specified in the Certified
Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC,-or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This request
shall be made within 30 days of notification by the Division.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the DWQ prior to a name change or change in ownership_
P.O. Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employes 50% recycled/ 10% post -consumer paper

Certificate of Coverage AWS090082
Double S Farm
Page 2
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual non -discharge permit by contacting the engineer listed below for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
The subject farm is located in the Fayetteville Regional Office. The Regional Office Water Quality Staff
may be reached at [phone]. If you need additional information concerning this COC or the
General Permit, please contact Dianne Thomas at [phone] ext. 364.
Sincerely,
Kerr T. Stevens
cc: (Certificate of Coverage only for all cc's)
Bladen County Health_ Department
;Fayetteville Regional Office, Water Quality Section
Bladen County Soil and Water Conservation District
Permit File
NDPU Files

L,
• State of North Carolina
Department of Environment and Natural Resources
Division of Water Quality R E C C f V E D
Q h' WATER QUALITY sEcrioN
Non -Discharge Permit Application Form
(THIS FORM MAY BE PHOTOCOPIED FOR USE AS AN ORIGINAL) General Permit - Existing Liquid Animal Waste Operatigft 0
7 199
The following questions have been completed utilizing information on file with tllie D VAIRIFe7kie
review the information for completeness and make any corrections which are appropriate. If a
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
1. GENERAL INFORMATION:
1.1 Facility Name: Double S Farm
1.2 Print Land Owner's name: Murphy Smith
1.3 Mailing address: 19829 Hwy 131 S.
City, State. Bladenboro NC Zip: 28320
Telephone Number (include area code): 648-6244
L4 County where facility is located: Bladen
1.5 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a
copy of a county road map with the location of the farm identified): From Elizabethtown, take NC 242 to Bladenboro,
follow NC 131 out of Bladenboro to farm entrance on Lt. just prior to going into Columbus County.
1.6 Print Farm Manager's name (if different from Land Owner):eVt�
1.7 Lessee's / Integrator's name (if applicable; please circle which type is listed): Mulphy Family Farms
1.8 Date Facility Originally Began Operation: 01101
1.9 Date(s) of Facility Expansion(s) (if applicable):
2. OPERATION INFORMATION:
2.1 FacilityNo.: _09_ (county number); _82 (facility number).
2.2 Operation Description: Swine operation r
Fee er to Finish
2448- Certified Design Capacity
Is the above information correct? E�,Yes; Mno. If no, correct below using the design capacity of the facility
The "No. of Animals" should be the maximum numberFor which the waste management structures were designed.
Type of Swine No. of Animals Type of Poultry No. of Animals Type of Cattle No. of Animals
0 Wean to Feeder 0 Layer 0 Dairy
0 Feeder to Finish 0 Non -Layer 0 Beef
0 Farrow to Wean (4 sow) 0 Turkey
0 Farrow to Feeder (# sow)
0 Farrow to Finish (.4 sow)
Other Type of Livestock on the farm: No. of Animals:
FORM: AWO-G-E 5/28/98 Page 1 of 4 09 - 82

e 1!
2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): 54 ; Required Acreage (as listed in the AWMP): 47
2.4 Number o< E-_oo>nstorage ponds (circle which is applicable): j
2.5 Are subsurface drains present within 100' of any of the application fields? YES or tNO
(please circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES or (please circle one)
2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, NRCS Standards, etc.) (Swine Only)
YES or NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited? ! —
What was the date that this facility's land application areas were sited? J —`j —
3. REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
Applicants Initials
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
}�
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
33 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CAWMP, it must be completed prior to submittal of a General permit
application for animal waste operations.
The CAWMP must include the following components:
33.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
33.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application.
3.3.4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
33.7 The PAN applied to every land application field.
3.3.8 The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.3.10 A site schematic.
33.11 Emergency Action Plan.
3.3.12 Insect Control Checklist with chosen best management practices noted.
3.3.13 Odor Control Checklist with chosen best management practices noted.
33.14 Mortality Control Checklist with the selected method noted.
3.3.15 Lagoon/storage pond capacity documentation (design calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility_
33.16 Operation and Maintenance Plan.
If your CAWMP includes any components nat shown on this list, please include the
additional components with your submittal.
FORM: AWO-G-E 5/28/98 Page 2 of 4 09 - 82

a . .6
Facility Number: 09 - 82
Facility Name: Double S Farm
1yo-1N1sth0%8 Pe0n9
4. APPLICANT'S CERTIFICATION:
1, ��,�fi��� �,,�,�� (Land Owner's name listed in question 1.2), attest that
this application for I )ICUe- t-Z-11 (Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned to me as incomplete.
Signature �j'JL,, - _ w - J Date -
5. MANAGER'S CERTIFICATION: (complete only if different from the Land Owner)
(Manager's name listed in question 1.6), attest that this
application for
has been reviewed by me ai
application are not complet,
package will be rurned as
Signature
LjL a b1<� t-) 1� (Facility name listed in question 1.1)
is accurate and complete to the best of my knowledge. I understand that if all required parts of this
and that if all required supporting information and attachments are not included, this application
Date / Y-9f. -
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
FORM: AWO-G-E 5/28/98 Page 3 of 4 09 - 82

Animal Waste Management Plan Certifications) -��� ���
(Please type or print all information that does not require a signature C
Existing ' r- ' New : or E:cpanded {lease circle one `filV �?"
General Information: WATER En QI-'/ f 1' S�r�r r,r,
Name of Fain �� r'ol� S . �^ Facility lro �'� ' Ent.
Owner(s)Name:_ M.�r,o -ATM+ _ Phone No: 6Y<S-148-Z-4
Mailing Address:_ t q Q1 A C"J,_ tJ r__ ? 9 3 ZD
c
Farm Location: Fourteen Digit Hydrologic Unit:
Latitude and Longitude: -�4° 7V q-'_2"/ -1 S" ` i' 0" County: _E(a-d-e
Please attach a copy of a county road map with location identified and describe below (Be specific: road
names, directions, milepost, etc.): _ N e. l31 -- I .q ,,; 1kxr 4L of _ _ _ab . L Z r i w. ,K)
Ooeratio❑ Description:
Type of Swine No. of Animals
❑ Wean to Feeder
;Feeder to Finish IIH-0
7 Farrow to Wean
❑ Farrow to Feeder
* Farrow to Finish
Type of Poulin• No. of Animals Tape of Conle
* Layer ❑ Dairy
❑ Pullets a Beef
No. ofAninzals
Other Type of Livestock: Number of Animals:
Acreage Available for Application: 5 Required Acreage: 47
Number of Lagoons / Storage Ponds : 1 Total Capacity:Cubic Feet (ft3)
Are subsurface drains present on the farm: YES o NO (please circle one)
Owner / Manaaer Agreement
I (we) verify that all the above information is correct and will be updated upon changing. I (we) understand the operation and
maintenance procedures established in the approved animal waste management plan for the farm named above and will
implement these procedures. I (we) know that any expansion to the existing design capacity of the waste treatment and
storage system or constrsction of new facilities will require a new certification to be submitted to the Division of
Environmental lklanaaement before the new animals are stocked- I (we) understand that there must be no discharge of animal
waste from the storage or application system to surface waters of the state either directly through a Iran -made conveyance or
from a storm event less se:c:e than the 25-year, 2—.-hour storm and there must not be run-off from the application of animal
waste. I (we) understand that run-off of pollutants from lounging and heavy use areas must be minimized using technical
standards developed by [he Natural Resources Conservation Service- The approved plan will be Fled at the farm and at the
office of the loca3 Soil and Water Conservation Di57iCL I (we) know that any modification must be approved by a technical
specialist and submitted to [he Soil and Water Conservation District prior to implementation. A change in land ownership
requires written notification to DEM or a new certification (if the approved plan is changed) within 60 days of a title transfer.
Name of Land Owner: lYl►k1-
Signature: 22. .- , IX
Name of Manager(ifdifferent from owner):
Signature:
Date: A 7 - 9 /.
Date:
AWC -- April 14, 1996

Technical Specialist Certification
I. As a technical specialist designated by the North Carolina Soil and Water Conservation Commission
pursuant to 15A NCAC 6F .0005, I certify that the animal waste management system for the farm
named above has an animal waste management plan that meets or exceeds standards and specifications
of the Division of Environmental Management (DEM) as specified in 15A NCAC 2H.0217 and the
USDA -Natural Resources Conservation Service'(NRCS) and/or the North Carolina Soil and Water
Conservation Commission pursuant to 15A IN 2H.0217 and 15A NCAC 6F .0001-.0005. The
following elements are included in the plan as applicable. While each category designates a technical
specialist who may sign each certification (SD, SI, NVUP, RC, 1), the technical specialist should_:only
certify parts for which they are technically competent -
II. Certification of Design
A) Collection. Storage. Treatment System
Check the appropriate box
] Existin, facility without_ retrofit -(SD or_WL'P) -
Storne volume is adequate for operation capacity; storage capability consistent with
waste utilization requirements.
❑ New. expanded or retrofitted facility (SD)
Animal waste storage and treatment structures, such as but not limited to collection systems,
Iagoons and ponds, have been designed to meet or exceed the minimum standards and
specifications.
Name of Technical Specialist (Please Print): S2r unl f:_ LA!rnrrnn awl
Affiliation: `.�,DA - Natural Resources Conse a e t,-2
Address(Agency): ?7 A°• Service Cer, t;.r. Lliza6ethtpwn. Nr 9R'1R7 Phone e ? =
SignatureI'le, . 17C Date: 6--7—y6
B) Land Application Site (WUP)
The plan provides for minimum separations (buffers); adequate amount of land for waste
utilization; chosen crop is suitable for waste management; hydraulic and nutrient Ioading rates.
Name of Technical Specialist (PIease Print): Samuel G. Warren, CC
Affiliation: •-, :7A - Natural Resources Conservation Service
Address(Agency)122 Ag. Service Center, Elizabet? town. NC 23327 Phone No.: 91
0-8 4_z;
Signature: 7Z)G Date: 7_ 9
C) Runoff Controls from Exterior Lots
Check the appropriate bo:
❑ Facility without exterior lots (SD or WUP or RC)
This facility does not contain any exterior lots.
❑ Facility with exterior lots (RC)
Methods to minimize the run off of pollutants from lounging and heavy use areas have been
designed in accordance with technical standards developed by NRCS.
Name of Technical Specialist (PIease Print)-.
Affiliation:
Address(Agency
Signature:
hone No.:.
ate:
AIVC -- April24, 1995

l
D) Application and Handling E ui rnent
Check the eppropriare boa
Existing facility with existing, waste application equipment (WUP or I)
Animal waste application equipment specified in the plan has been either field calibrated or
evaluated in accordance with existing design charts and tables and is able to apply waste as
necessary to accommodate the waste management plan: (existing application equipment can
cover the area required by the plan at rates not to exceed either the specified hydraulic or
nutrient loading rates, a schedule for timing of applications has been established; required
buffers can be maintained and calibration and adjustment guidance are contained as part of the
plan).
G New or exoanded_ffacility; or existing facility without existing waste application equipment (I)
Animal waste application equipment specified in the plan has been designed to apply waste as
necessary to accommodate the waste management plan; (proposed application equipment can
cover the area required by the plan at rates not to exceed either the specified hydraulic or
nutrient Ioading rates; a schedule for timing of applications has been established; required
buffers can be maintained; calibration and adjustment guidance are contained as part of the
plan) -
Name of Technical Specialist (Please Print):
Affiliation: JA - Natural
Address(AQency):`— A9 $erVICQ �hone No.:
r _..... L ..�!
RV
C
III. Certification o, f Installation
A) Collection. Storage. Treatment Installation
E-7—yer ' a
Ne-v. expanded �or retrofitted facility (SI)
Animal waste storage and treatment structures, such ?s but not limited to lagoons and ponds,
have been installed in accordance with the approved plan to meet or exceed the minimum
standards and specifications.
For existingfacilities without retrofits, no certification is necessary.
Name of Technical Specialist (Please Print):
Affiliation:
Address (Asency):
Signature:
hone No.:
ANVC -- April 24, 1996
3

B) Land A DIication Site (WUP)
Check the appropriate bar
! The cropping system is in place on all land as specified in the animal waste management plan_
J Conditional Approval: all required Iand as specified in the plan is cleared for planting; the
cropping system as specified in the waste utilization plan has not been established and the
owner has co=, Atted to establish the vegetation as specified in the plan by
(month/day/year); the proposed cover crop is appropriate for compliance with the waste
utilization plan.
❑ Also check this box if appropriate
if the cropping system as specified in the plan can not be established on newly cleared
land within 30 days of this certification, the owner has committed to establish an interim
crop for erosion control;
Name of Technical Specialist (Please Print): 5. a rr. i it - s' a
Affiliation:_ Natural Rp:curn,ps Conservation Service - --
Address (Agency):, 22 Aa. Service Center, Eliza bethto-vin. NC 28337 Phone No.: 914-862-692"
Signature:, �5 6 - l 1; Date: I —7- ¢-1
This following signature block is only to be used when the box for conditional approval in III. B
above has been checked.
I (we) certify that I (we) have committed to establish the cropping system as specified in my (our) waste
utilization plan, and if appropriate to establish the interim crop for erosion control, and will submit to
DEM a verification of completion from a Technical Specialist within 15 calendar days following the date
specified in the conditional certification. I (we) realize that failure to submit this verification is a
violation of the waste management plan and will subject me (us) to an enforcement action from DEM.
Name of Land Owner:
Signature:
Name of Manager(if different from owner):
Signature:
C) Runoff Controls from Exterior Lots (RC)
Date:
Date:
Facility with exterior lots
Methods to minimize the run off of pollutants from lounging and heavy use areas have been
installed as specified in the plan.
For facilities without exterior lots, no certification is necessary.
Name of Technical Specialist (Please Print):
Affiliation:
Address(Agency): Phone No.:
Sit nawre: Date:
AWC -- April24.1996

D) Annlication and Handling Equipment Installation (WUP or I)
Check the appropriate bock
Animal waste application and handling equipment specified in the plan is on site and ready
for use; calibration and adjustment materials have been provided to the owners and are
contained as part of the plan.
❑ AnimaI waste application and handling equipment specified in the plan has not been
installed but the owner has proposed leasing or third party application and has provided a
siUned contract; equipment specified in the contract agrees with the requirements of the
plan; required buffers can be maintained; calibration and adjustment guidance have been
provided to the owners and are contained as part of the plan.
❑ Conditional approval: Animal waste application and handling equipment specified in the
plan has been purchased and will be on site and installed by
(month/day/year); there is adequate storage to hold the waste until the equipment is, installed
and until the waste can be land applied in accordance with the cropping system contained
in the plan; and calibration and adjustment guidance have been provided to the owners and
are contained as part of the plan.
Name of Technical Specialist (Please Print): _
Affiliation: USDA nllatpiral
Address (Agency):
Signature:/`
�DC
hone No.:
ate: 16/'-
The following signature block is only to be used when the box for'conditional approval in III b
above has been checked.
I (we) certify that I (we) have committed to purchase the animal waste application and handling
equipment as specified in my (our) waste management plan and will submit to DEM a verification of
delivery and installation from a Technical Specialist within 15 calendar days following the date specified
in the conditional certification. I (we) realize that failure to submit this verification is a violation of the
waste management plan and will subject me (us) to an enforcement action from DEM.
Name of Land Owner:
Signature• Date:
Name of Manager(if different from owner):
Signature: Date:,
Please return the completed form to the Division of Environmental Ianagement at the following
address:
Department of Environment, Health, and Natural Resources
Division Of Environmental Management
Water Quality Section, Compliance Group
P.O. Box 29535
Raleigh, NC 27626-0535
Please also remember to submit a copy of this form along with the complete Animal Waste
Management Plan to the local Soil and Water Conservation District Office and to keep a copy in
your files with voter Animal Waste Management Plan.
AWC -- April24.1996

JJWZ�""',
�... ,•-• .', 1. �„'-�` _
3y - -:: - r � t �J1! 1, - ✓
r y wi.:� � �f� •.ter �r y;�',;-.�__ ; i- f:..- ; .L +r.'r�•C. _ ' :-'1'... rtti 1..[il;.ry�.r . � �Tzl�• -C
'+�.r 1rr��. r ? � � _: �F .. � r av r•i1` #�1i-.r'y �• f �� 'p•Y' � - Jj- �
tri�'��=s i�r �•% ry}�--!1it''ri.s .z4 �' •--r : j rr} ' �r�'w ...�rr JF � r: �
�• � c• -' - y • �� �.; iv I- JCr x M - J,-- ,�i� ` � -:'.. • -c'i.ti "•i. -,% `i`.. -
`-��+� � �^�i� { �i'n -��� - v f _ � •+�ri:tY�.~r ti`��i=:'^ �}S, _ � -" }� r.t� �L'-:'�`i
,S 'a'ti -.'?. : �r X v�Y''•^'��tit3•z. -1'r. S{ ?y. ier. ,•� ^"Y>;,:�.•,:�: t�:,.-`'':.
� a; s - ti J � `''. �1'�"a;;' i'^4•����� � �l _ �" R r � j� •�'S < +'� �'r ` �)j'
�'-`5.r�+-.f4 -. r !� r '+�•4 r�i•'{i. �; '�r., � �• a.. ��,. ..! r ,-.._ �•�.�'�k. �^- 3`~ -
f ti'if s 7fi,•; � _ � t f i :iI ! r 1-7 _.�'-.bl _ �l ' ' 1 r �:•' J�- ,F�r.- as �. : L� _ .1 .�-1 t'� `x` t ..�'+rj
.,d'�•...-+a�?�;° `�'_:'• ''��-�J :c '•.-;,;...;'•�•i' �'�_ .-i-- -s `'r�•G`�t-y..rrc.FFyY f- + ;a�'-'� L-
.14
`L•t � � �Y-y;r " .. t f i .�' :. f Y p�- � - y � F• y. J '1.� tdL - c+ r �,'F _
. t±7Li„`rS!'y"F� „s --- ��,�-r .�-� � 4'. _ .ti•4.+r r -_'- i_` ,..�_y�_ 1 y�
16
��'�� �r?j-;R� � � i; _..' .` �C�w n,��•,j e - _ -�+�-.==` ; - .• 1 - 4ri _ ram,' _ h!+-r' {r - .s
���-'r;S�T �,^r� `r `Lj'a 4.p... _ - f_, y.'- r x3 T�7, ,r ---1 r - }•;- ,�,a. -
�, rt:• Y � � 4.�, _ t7 _ i � � . 7 s 1s� Y - .� 3�,.- Fa j rt• -s...� �t • � f - { j,`• _
�- •4'iAy � ✓ Y .i�a! � Z ' rt' � } y j i jr � r S r! •�yi�'/.j��, tj L.! "ti '� rr �I�'' �+ \ - _ .'__

;DA--SOIL CONSERVATION SERVICE UNITED STATES
-_22 Agriculture -Services Center DEPARTMENT OF
,Elizabethtown, NC 28337. AGRICULTURE
,[phone]
Z2._q r RECEIVED
WATER QUAUTY RECTON
OPERATOR: MAR 1 1999
NmDisclarge .
This is animal waste s*!m design and specifications. Please revs it
carefully. Retain this plan for your use and records. It is strongly
recommended that your your contractor and Soil Conservation Service
personnel are in agreement as to how the waste lagoon is to be
constructed. SCS personnel will meet with all concerned parties and
walk over the site to explain all flags and -markings. If•further
layout is required by the contractor than is provided, feel free to
contact us. It is important that everyone understand what is expected.
so that final construction/seeding meets plans and specifications for
certification.
As you requested, this design contains no added volume -for sludge
(solids) that will accumulate over time . Sludge will be removed as
needed, however to maintain the efficient operation of the system.
The lagoon embankment has a HAZARD.CLASS "A" design. Sudden failure of
the embankment will not endanger life or damage public transportation
facilities. If failure should occur, lagoon would drain into
'j�>aoe!,,c� which is /op' estimated, feet
from lagoon, which in turn would eventually drain into
The actual amount of material required for pads and dam may vary from
the estimates. The design will attempt to balance cuts and fills as
close as possible. If additional material is required after
construction is complete'on the lagoon, the*contractor and owner will
negotiate on the price and location of borrow areas. Any movement of
topsoil is in excess of amounts specified below.
NOTE: Design Capacity ' = 9.6D� 3
(excludes V freeboard)
Excavation Estimate = S 3
Embankment Estimate = Z 3
Estimation of Pad, Fill
:j Cut -Fill Ratio
E
JOB CLASS -77L-� DATE, ! 2 Z-q'!
Designed by: 1;,g
Design Approval:, Date

.�y}y,i•�-s,.�. "mac:. t'_ -: _ - - -�,�• .r� f
;':s}v�-ice -'.11: 1 �4: 1'..� • h �r
�° yL Z .} v. •;' r �t.-r � �' 1 f � r � � : ' � A .' ... - - .-... �6r.,s.wr �
.. .!"' -- r s f • 4 k�•r'ur [ -.t - I_`t,y`�'�•T,' •::, r: e.:-rt:
'iY.-d,y `r -`t'-. _.�=iT�-,._y. V ti.t`� e4JF' �. 6.. ���:•__ ��: Y_o-_Y� ��J.
?� r �.. ,',�r,"~� d r - •s-.- • �i:, ;,; <-,r a:^.,,n -Sr - .•�!�--ee'•y' '� � � '�' ' .^ r rL � '? f'i ' __
� ' •f :`:. ti= . •'.�.+ - . r,.�'-• y • %a� ,J.`': y-cam. � _
f ,•: �'Oi�?s. ...b�. %�/; _�!: ��3• �ifa1_"'�a.. '. :Y' r'ar7.%:Y r_'�-`^7 �� is r * - �i• rr.^`: Jt•'1'- '��
rf;,? ,r.!•� icy.-- fva, � "i.-: i J'._ _ - r� � $t•_ -�.' • - !� -'T• � f s
�s-'� L �� s''-�-•s. �.s=4•_.�;y'?''�°'r�. rr �•- �i'',�• �!� •ice f � •"ti~ •'r z IT
.�+­5 70, 4:: irr�" l� 1• `: �C.ri ,a ` a ._�
- >� - '• � ' �� -• � Yam' A:�'. .er- r - ,.: F+r-' � '
,'a: a '{"`.V ' � -r _i= :_ '�'-:'r a•:, Jyr f : z `�
•�- -_y ~' ': _ - _s„ Y ,�.Y;,.e.i.r-: 1• •:- ,,..i_•' . _ _ ttx ^i �zt- �;^' _ �`K _
y�� C, - �'r '-.,,. ` -t• 1 r • � '�.. , n v+r ' i ' � - - 11 t � I¢ }`' - >s'. f c_' _ _ _ _ r ;,y.. ¢ _ ':.'
Fn_ .�_���. '.�� `�-'i-ti•.' ..r, _�•I •'- rY. �c��,•-' -J.'- _ [-�- _ ^t"_ i �:✓v': 3,i:.�,it�w'7 ��'•--�"y�•~.c`T_y
L--iMEN
l t•. r-z'Y'. �•� a'`f'" _ � "�'r =.i='�::'s-"."�.+...".`_�� .'4_':' s t:;r r,rf �w< [�4-��K'':., ,c-; y�ff"��a j��f,-•p:'..:,-y x.
•%i�r. '�Y�'��wtL�.��::•x__� - �L �+•y- _ _��'S` F- - , - - ~ 'r �• ��-��. :� '',+¢ci,ti }
' `,* ...• •v -- r- :�Z� CS r t y 1 - r �'' y �t - ",�-,�J. ,�,� �� r.; 'c.K : :'+' Y -
'�'`•��' rJ��-�s��� 1�.rt ..�; i s i, i - S rr � '>a r � ., r . � }� '-• �L�j:r 4 -: • N.�:
'R'} j�`.., .. s?�^5j-�'s`3 �..s�Y � `t - �• ..�:. • J• pia � � J;�- _ � F _ �'.� ., � •c „ _- . �-i
J :.� -� •rY.. ,x _ �� � t - �7^ �y, _ r- -s-- [rlttl� 'tir•
--� - • � .;:i: l�v� i � �-t+. ' u �� � sad r x, .% - �- � °_ ` � � i ,. - - L,s .. - "
•Y�y �-.^j:f��y �YS- �S .�•s}'f(. +r ti4`: :!+•_''��ST-C 'r {~���bL r' ��-�r. r ��� � S ��r ..-��t ••` r��7 _
-�+ J_•3.1C.. •' ,-�y^ � 'L t � •'t ' - ` yi:, � 3 � 'C.. a f ' `+ri 't4 '.L; i .� `''r"_�:�; a� •.�k��-q�r��::5^{ Rom.;- ~'!.. ,� Lys`_>4; fF_;r ri;-s r�1�� � ?- ti„- ts�. "�^'.•• •>•:_. �' :y,ra Wit•.; -_ -
Syr is yaYk •`-� � {: '�,;� x.!� w - 4d�.�' } [ �.ir' oiI _ • �r 4 ti �� _
•�+�.- >~:`' -r''eC: ti � + i�C' ?h +� �'�- f5 �y v�^�z s _ y � 'jY'[ ['� t,S

1 I 1 M f
ARM
1 > �' i t 1 1 ■ '
�!-`• _.-�li'v�-yam _ - !,ri ft�'•� i �=L'�-.` �4��� 3�\• l •*, L .- y -
- ..ii�. �I+ � y" - �Z;� �.''•' ',`?:l.t1D` ��''`•'�.aF•• ��-"'J!in,`''.. Y _ �•s.. +/1`. �1.,. - _ �.-, - ,t
- _ ..,'.,.'f, - ��+(���a„�" ���: r '�=��c�..`�`s�=-%ant--_-::;?�m'7 _..,�, -'., .,� _ t -, _ �;, •
i -� s P.�\�•`y� •'�� t'r`��5� ��• *. p•�'�l.�t7�e.€22< - �..y��+l,��i��� _-E--� �O`_• - - .. ._, s..
^- .t 4+i �A � 'S•=xti'.."'C?�•,`►.�1,�` +•: �► *�, �7 �-i I.y' �'�� •:rs r - -K -_ - .. - '3
.� ` ,. 1-�' I ,� � �..., �� "�i.. f: 11"_i.�'-',` � 7, -•'G� �y�`y - L- 'iC / _ _ _ JS 'x,= _
+ ,� _- _ %�; �` � -- . - 'r.•' � Lyra_ i► �,' - .,
ay �` r'
'1
•jirr - - - .- 'Y.
ti r „ : ' ,��.t !'fi�r �' . - � ;� . ,•ti.;�. e.'_ r - ' _ : ' _ - -r: s _
+'1. - iV - :.��' _ - �fl, � .f-•. ,� r , _- :r.+i•a�•n>'i !i-. �1'•'�1� � �� _
ri ��^^� •t .�•ti��'« <� k\rt� `,: _• - :l,:f � a:.l `:����• _ ____ _,�.i } ems.
.fit -•m % l�' i `.j'-'+ - ' -. _�r- -�
f _�� T' �_ - - _•;:,;� :.,ter._,, � �' �-:•���_:;: -� '-� '=
Ile
RK
r
35. � ', - '•Y,y� '. � mil.~. c �- -... F - -
.4 • - -.c! _ I ice.:' . m::•
7a► •'er a,:._ ',:,- -
yi-

Ff _
U. S. DEPAHi MENT Of AGRICULTURE
SOIL CONSERVATION SERVI6Z
SOIL INVESTIGATION TO DETERMINE SUITABILITY OF PROPOSED POND SITE
FARMER'S NAME ti4I DISTRICT
DATE ► COUNTY
PHOTO WORK
WATERSHED AREA MEASUREMENTS
•. 1 -ACRES PASTURE ACRES
WOO 1 1 TOPOND CLASS WORK• f
SKETCH OF •'• 1 '• i SHOWING WHERE BORINGS WERE MADE
Locate r�ierence point in center line of dam and Idenfify an skgtc&
■e■■■■re■er■
r■e■r■■erer■�
■rrr■r■■
®ere■■er■■
■■erre�■r
r
■NMEMMEeeerer■EEMEN?�■1r■IN
■
e■e
e�eee■eereeee���■
■■e■■r■
MEME
rrrre■e■■4�.�■®
SMEME
N■r■■■
■NseeeEMMEMME
■r■�r■eer�e■■
■■�r®®corer®®®®
EMENMEMEMEe�MEMMEMMIer■N■e■
eeeee■�e■■e■ee®■■®ee■■er��■
�■e■er��er�rree�e®ree©©e���■�.
er■■rm1e
■■■
r■e�ee�e�rrr��ree
EEMME■
mom
■■MINNIN■MMEEM■
■e■ee���e■r■ee■■eeeeeeei��
■■■�r�leeeerrr■�■®■
■r■r���r
■ere�■r■■®�■�e■rii■eei�ee�r
■■■■eree®■ee■ee■■eeeeeree■;
moo=rr■r■eere■e■eeee�■e■e
f0,
BORING. PROFILE
Make and list dam -site and spillway borings first. then ponded area and borroup pit burings-ievarate with Lwrtfcal red fine.
(Continuedon back whery nece"arW Show wafer table elevations on dam -site boTings.
01
�li3iQ10=001
01010ml�lR�lE�IQ�imP�l
��l
I�€!�''rlr{■1■
■lri
■Irlrl
■lrlrlrle!,■l■l�lrlr
iIM'�i
Mim;e►■ur�i�i■
®i■r�e�r�rE■ir
ear
rir
■ie
■
■�■
R�mi■INIMINIMMI■S
I■€rINIe1■lrtel■I■I■W
[N
C�®:'■1�11��rI�le1■
■Iel■1■lel■l■lrlrir;■I■Irlrl■
�®'■I�€�}■�I®l■
■I■I■Irl■lrl�l�lelrl■1■f■I■lam
�Il■l�l�?el
I�€■rl��■€r€■l�lrlr€�€ele€e€rl■€■
®`rlrlIDlrlrirlr
lr��l■€■i■I■Irlelrl■I
I
€
OIC■I�MOM
irI
INIENIMEfrl■�r(■�rfr(r
Ni■ie�e�e�e�e.■�e�■�e�■
■�era■eae�
r_
a

j
4
t
Animal waste lagoons are designed with permanent storage
(waste treatment;volume) and temporary storage.
The designed 6 g6nth temporary storage is an estimated
volume based on: 1) waste from animals; 2) excess rainfall.
after evaporation; and 3) the largest 24 hour (one day)
rainfall that occurs on the average of once every 25 years.
The volume of waste generated from ,a given number of animals
will be fairly constant throughout the year and from year to
year.. The excess rainfall will vary greatly during the year
and: from year to year. This estimate is based on 7 inches
of excess rainfall which is equal to or exceeds the highest
6 months excess..`.in a year. The average annual excess.
rainfall is approximately 8 inches_ Therefore, an average
of 8 inches of excess'ra.infall will need to be pumped each
year. The 25 year rainfall wiiI not be a factor to.cansid`er
in an annual pumping cycle, but this storage volume must
always be available. A maximum elevation is determined in
each design to begin pumping and this is usually the outlet
invert of pipe from building(s). If the outlet pipe is not
installed 'on the elevation to begin pumping, a permanent
marker must be i-nstalled on this elevation to indicate when
pumping should begin. After initial filling of lagoon, a
minimum 6 feet depth must be maintained for anerobic
treatment of waste. An elevation must be established to
stop pumping to ''maintain the minimum treatment depth.
Pumping can be started or stopped anytime between these two
elevations for operating convenience so long as site
conditions permit (conditions are weather, soil, crop, and
equipment to apply waste to prevent runoff or leaching).
For t1jis lagoon the maximum elevation to begin pumping is .
`' $eet and the minimum elevation to pump to is9'feet.
The design temporary storage, less 25 year storm, is /;L-ja7
cubic feet or Z,503 gallons. As stated before, this volume
will vary considerably from year to year.
This lagoon is designed to flush buildings with recycled
lagoon liquid, and fresh water should not be used for
flushing after initial filling.
l;

OPERATION AND MAINTENA_NCF.. PLAN
i
-his lagoon i s designed f or was to -treatment w'i th minimum
odor control. The time required for the planned level to be
"eached may vary clue to so i I cond i t i ons, f I ush i ng •
operations, and the amount of, fresh water added to the
system. This lagoon does not have design'storage for fresh
►ate r, Once the effluent depth in lagoon is :adequate f o r
-eoyc l i ng -flush, Fresh water should not be used. Lagoon is
designed to store a 25 year storm rainfall event plus normal
rainfall in excess !'of evaporation.
I "
Land application of: waste water is recognized as an
acceptable method 65f disposal. An irrigation system (soli-d
set, traveler, center pivot) is the most efficent method of
application. Care.1needs to be taken when applying waste to
prevent damage to craps or runoff from the field. Rate of -
application should not exceed 0.5 inches per hour. Waste
should be applied according to soil -test and watee analysison actively growing; (grass) or immediately prior -to planting
(corn) .
The fo-Ilowing items are to be carried out:
1. Begin pump --out 'of' the lagoon when 'f I u i d 1 eve l reaches.
the bottom of the outlet pipes. Lagoon is designed
for 6 month pumping cycle. ELEVATIONf}.-S $p.3
2. Stop pump -out b'ef ore f l u i d depth is I ess than 6 f eet
deep (th i s prevents the I oss• of bac ter i ,a) . ELEVATION 4p,3i
3. It is strongly recommended that the treatment lagoon
be precharged to 1/2 its capacity to prevent excessive
odors during startup. Precharging reduces the concen-
tration of the initial waste entering the lagoon thereby
reducing odors.. Solids should he covered with effluent
at all times.
4. Keep vegetation'on the embankment and areas adjacent to
the lagoon mowed.
5. Repair any eroded areas and establish in vegetation.
6. Recommend that a suitable fence be constructed around
the lagoon for �afety purposes.
7. The Clean Water:Act of'•1977 prohibits the discharge of
pollutants into''waters of the United States. The
Department of Environment, Health and Natural Resources,
Division of Environmental Management, has the
responsibility for enforcing this law.
8. All surface runoff is to be diverted irom the lagoon to
stable outlets. '
NOTE: An analysis of the waste water can be obtained at
commercial laboratories or at a fee of $4 per sample
at: N.C. Department of Agriculture Plan Analysis L•ab,
Agronomic Division, Flue Ridge Road, Raleigh, N.C.
27611 (Telephone [phone]).
f,

eii
er ator:Murphy Smith County: Bl aden Date: 4/22/91
Distar„_e to, nearest res i dence (other` than owner-) : 2C:00.0 feet+
1. STEADY STATE LIVE WEIGHT
tl sows 'N 0 1I.•s. =
0
Ibs
boars x. f bs. -
tj
1 t•s
C? i i tters x 10.0 pig;/litter x 30 I bs. /pig =
C?
I bs
0 sows (farrow to f i r, i sh) x 1417 tbs. =
0
1 t•s
it sows (farrow to feeder) 1522 1bs.
0
It•s
2448 head (finishing only) 135 tbs. -
-_'04,=0
TOTAL STEADY STATE LIVE WEIGHT (SSLW)
3'30420
f b s
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
3r f urne = '=:'04C,G i bs. SSLW x Treatment Vo I urne (C:F) / f t•.
SSLIQ
Treatment Vo I urne(CF)/ f b. SSLW= 1.00 C:F/ 1 b. SSLW
Volume - 3304,:-0.Cs cut.'ic feet
INSIDE TOP Length X Width X Depth
( Inc: I . Fr'eeb-:-ard )
- . DESIGN TREATMENT VOLUME 100. 00 Z40.00 10.00
Ma i nta i ri treatment I agoors f i qu i d level at o f evat i on
4,7-ry'
fee
Bott•_•frr of' lagoon elevation 51-.4557 feet
3
`4• q
Lagoon size (for treatment lagoon I i qu i d volume) using
Fir- i smoda I formula
LENGTH WIDTH SS/END1 SS/END';: SS/SIDE]. SS/SIDE:
DEPTH
271=:.4 21:?.4 3.0 3 .0 3 .0 3.0
6.4
AREA OF TOP
LENGTH * WIDTH =
278.4 t 18.4 r_ 0,-:--Cf'2.6 ( AREA OF TOP)
AREA OF BOTTOM
Lt. * Wb =
240. 0 1 .0 . Cr 4 32-0 3.0 ( AREA OF BOTTOM)
)
AREA OF MIDSECTION
(Lm * Wm) *4 =
215,9.2 199 0r-'.5. _: a . r• ( AREA OF MIDSECTION * 4 )
CU . FT. = [AREA TOP + (4*AREA MIDSECTION) + AREA B13TTOM ] * DEPTH/6
VOLUME OF LAGOON AT Ti;EATI TENT LIQUID LEVEL = 3'.31 "235 .3 CU . FT.
4. TOP OF LAGCif=i,N1 ELEVATION (INCLUDES TEMPORARY STORAGE AND FREEBOARD)
SI- 9
PI are spo i f as d i ice to sett I ed top e I evat i cn feet.
(plus 10% for settlement)

TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of d i c e)
Lengthy * Width =
_,00.0 E4cy.i,i 72_'C)00.C► square feet
Bu i I d i nos ( roof and I rat water )
Length, * Width =
0.0 C).0 0.0 Square feet
TOTAL DA 72000.0 square feet
PUMP i ng cycle t _d t.e 1::-30.0 days.
Fit. Volume of waste produced
Approx innate daily production of manure in C:F/L%. SSLW C).001=5
Volume = 3'-' 74.30.0 Lbs . SSLW * C:F -if Waste/LEA . /Day 180.0 days
Vc, I ume = Si) 'O6..6 cub i c feet
5B. Via l urne of wash water-
This is the amount of fresh, water used for washing f I oor_s or- volume
of fresh water used fur- a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
VO I Lime = 0.0 gal I ons/day 1E.0 jays in cyc l e / 7.4 . gal l on
per cu. ft.
Vv I urne = 0.0 cubic feet
5C. Volume of ra i nfal l in excess of evapi:,rat i Ln
Use period of time when rai nfaI I exceeds evapuraL i-+n by largest ammunt.
Rainfall tc, - 4:�.0 i nc h e s
Evapor. - 41.0 inches
Excess rainfall (difference) = 7.0 inches
Vo I Lime = 7.0 in * DA / 12 inches per foot
VC-4 1 urr:e = 4'2'000.0 cubic feet
to
L

` 2'5 year - 24 hour- storm
re =
7.0 inches / 1Z inches per foot * DA
Vo I urne = 42000.0 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A.
80306.6
cuL.ic
feet
5B—
0.0
cub i c
feet
5C-.,
4,= OOO.0
cub i c
f eet
5D.
4Z000.0
cubic
feet
Subtotal
164306,6
cub i c
f e e t
TOTAL REQUIRED VOLUME
4947E.'6.6
cubic
f e e t
TOTAL DESIGN VOLUME
499608 . 0
c ub i c
f e e t CLASS III DESIGN
6. DEPTH OF STORAGE REQUIRED ( ABOVE LAGOON TREATMENT VOLUME ELEVATION)
Depth, required = Volume of temporary stor-aGe divided by the
average area of the tempc,r-ary storage
Depth required = 164:--:06.6 cubic feet/ 6.4799.3 square feet
Depths required = 2.54
Top, ref dike elevat. ior, feet
Lagoon treatment i i qu i d e I evat i or, = feet
Depth, between tops of d i ke and treatment I i qu i d i eve 1 3C:.6 - feet
Depth required M Z.54 feet
Freeboard - 1.00 feet
Total depth required = _:. 54 f e e t
NOTE: I F THE DEPTH E.ETWE=EN _`OP OF DIKE AND TREATMENT LIQUID LEVEL IS EQU.
1-0 OR GREATER THAN THE TOTAL DEPTH REQUIRED, THEN ADEQUATE STORAGE
HAS BEEN PROVIDED.
7. LAND APPLICATION OF EFFLUENT FOR NITROGEN DISPOSAL
*PRIMARY EFFLUENT DISPOSAL AREA*
TYPE OF OPERATION : farr--jw to feeder -
TYPE r=]F VEGETATION ; c o r n
ANIMAL UNITS 2448.0
ACRES / ANIMAL UNIT : 0.0150
Ti-iTAL ACRES 36.7
*SECONDARY EFFLUENT DISPOSAL AREA*
TYPE OF OPERATION :
TYPE OF VEGETATION :
ANIMAL UNITS :
ACRES / ANIMAL UNIT :
TOTAL ACHES
DESIGNED DY : �RrwTif �.(i(liRQr�
DATE:
0. it
0. 0000
0.0
APPROVED E:Y /��G�c..-- � C•
DATE

r• �
OPER AT�ON 8tALUNTENANCE PLAN
Proper lagoon liquid management should be a,'yially
�r-round priority.. It is e�Speci
inmormnt to maaz;e ICvels so that: you do not have problems during extended rainy and
wergciods_ I "
Maxim= stogie capacityshouid be'available in the lagoon for periods when the-
recciviag � is dormant (such as winterdme`for berinuda.. ass) or when the= are
ex=ded r " soe?is such as- the tl und.-rsrorm 's=wn in the svmmm-time.. This m==
.that ar the ffin signs of plant growth in the iarPr winter/early seem irrigaaorr a�g-to
a fk nz Waste T"nagement YL= snoWalbe done: whmnever the land is my enough to
rive lagoon liquid. This wEi ma k:- sxorage space available in the lagoon for ftr�wet
periods_ In th*Into- summer/early j57--71 therlaaoon should be pumped down to the loin
mares (seer F,,-= 2-1) to allow for winter storage' Every effort should be made` to
mab=afn_ the hgoon doss to the for
liquid level is -long as the weather and vast-
utzZi7atiorr plan will allow it -
'Waiting until the lagoon has reaca6:d i;s mam' ,munz, storage` cznaciry before starting `to
iaigatdaes e not leave room for storing excess water. during ex=nded wet periods.
Oveulow from the lagoon for any re: on'except a 25--year, •24-hour storm is a viol "on of
state law and subject to penalty action. �
The routine =,==ance of.a lagoon involves the'foilow3ng:
Maimmnanca of a vege=ve cover' for the dam.
3escz:s or common de-mizd2g=s the mom common vegetative
covers. The,vegemdon should:be f=xtilizad`eacn year, irne_-ded, to
rominmin amorous stand: � The -amount -of ferdti,— applied should be
b2se on a soils test; bnr in the' event: that it is nor tr actical to obtain
a soils test each year, the lagoon embankment and surrounding areas
should be fats imd with 800 pouncs pera= of 7-0-10-10, or
e�uizzent. - ,
3rush and trees on the embankment must be controlled. This may be
Goby mowing; sttrayiug,'�raiing;.-chopping; or combination of
tale practices. This should be done ax least once a year and
possibly twice io years that weather conditions are fiavorable for
heavy vegetative givwth_ _
NOTE If vegam. on is controlled by,sprayingie, the is ide must not be allowed. to enter
the lagoon w. Such chemi6ah could, harm the br a in the lagoon that are t rating-
the waste_ s
Maintenance iusperdons of the en="i '1ag6'on should b� a
made'during the initial fillz' g of.
tic lagoon and at least monthly and, a'rtr-L major rainfall and.stortn events. Items to be
checked should include, as a MI*=ui, the following
Waste Inlet Pines, Re: ycling Pipes, and Ove -Bow Pipes --look for_
1_ scparationorJoints
2- car
ts or bre3ks
�. accumulation of salts- orrninerals.
4. overall condition of pipes .: • '

�x'�Xl f�4�r��L.�[�''�`: 'r•'�+ '�f��, k%„��'�.�t.• +�..h� � ,1..�.r� -�.�. i•k
.. '••f °,�'f-' - r.. a y►w vt ^F Y"}lY� y-"ice'^ �'3 -}
- ;+�;��1`a��:�{�,�4 s' S,*fir
,y, '���„ul.. i•.' F.1f
X- Ff ti..'
= -� 3��'i
s"`� `��y��.. i�,� _,'CH'_ �L. g�✓ j.�,
s
Lagoon sui ac.4-look for.
L undesirable've,-radve ciwth
2. floating or lodged debris
r
Embankment --look for
1. settlement, c acIdng;.-'Ci,'Jugt1 holes :
2 :side slope srabili°ty—�siumns or'.buiges', .
3. wet or damp arias on the baob slope
4. erosion due to lick of vegetation oras a result of wave action
5. rodent damage+ '
: ,.: ` t
larger iagwns may be subject to lin.-: dannge due to wave action caused by strong
winds_ These waves can erode the lagoon sidewalls,' thereby weakening the lagoon dam_
A good stand of vqr-mtion;will Diu='the poteatial damage caused by wave actia� if
- wave action mT, serious damage to aboon sidewall, baffles irr thedagoon-may be
used to redum the wave impacts... i..
Any of these features could lead. to orosioR and weake'�:ing- of the dam- 'If your lagoon has
any of then: fc=es,-you- shduld call -an- appr•op:ezperr -aarefamiliar with design and
construction of waste lagoons_' 'Yowma.y, nE d'to'provide a i--=;orary -fixif these is a threat
of a waste discharge.' However, T a be-mansnt solution' should 6e reviewed by the
t=hnical e-pert Any dtggzngµinroa lagoon `dam 'With -heavy eouinment is a serious
underaxing with motend*ally.'senous'consequences'and'sh_ ould not be conducted unless
recommended by an appropnaze=tectuiac�i:epert.�
'-'.baste: Puinpsn°for proper, opet�tion of:
1.. re: ychn� pumps.'
2. irrigation pumas
Check for lam, loose fittings;: z4a ove.-zil dump °one�ation. 'An unusually loud or ceding
noise, or a is ge arnount'of vibr�h&i, is is need or repair or
replacement r .
NOM Pumping systems be"insted`�ope`ated:utly
should and enough so that yore
are not completely "surprised ,by':ernupme7itrfailure.:f You should perform your -pumping
system maintenance at a time -whets your. lagoon is;atdts low level. This will allow some
safety time should major repairs be _equised_> Having a.nearly fall lagoon is not:the time
to think about switching, repairing- •or bon wing 'pumps. ;'Probably, if your -lagoon is RA
your- neiggaboes lagoon is fullalso::' You'sh6uld consider maintaining an Mveatory of spam
parts or pumps.
76
Sm *-ce- water- diversion features are designed to Cany all surface
t. ..
drainage waters<{such as,atnfall runoff goof drainage( "gutter outlets,
and parldng lot ruriofi� a""vayfrom your.iagoon°and other waste'
tteamzent or. storage :structures.=-,-The'oniy, water that should be
coming from your -lagoon is thaew' hich�conres'from your -flushing
(w�in� system pinesaandtti e'`raiii#ail,tliafhiis,the lagoozdirectly. °
_ You should inspect, your,mvemon `systezzi'for the`followinc,
I adequate vegetatzoR [ a '
4
2 r
diversoR' eanacrty •.;,r
3. ridge berm height ; `

.,`"'1}"fe� �til�l•iTer yTk$�3.�i96t }'.='i �.t;
r F 3 t sw RA ., k• r
• �s r 7 ���
• 1 i � _
Identified vroblems should be corrected promptly.. -It is advisable to inspect your 3v rz
during or immediately following a heavy rain_ If i=hnical assistance is needed to
de =nxine proper solutions, consult with appropriate experts_
'`you should reword the level of the lagoon just prior, to when rain is predicted, and tbea
record the level again 4 to 6'hours after the rain (asstunes the is no pumping). This will
give you an idea of how much your lagoon level will rise with a certain rainfall imount
(you must also be recording your raafali for this to w irk). ' Knowing this should hAeiv in
planning inigarion applications and storage. If your lagoon rises excessively, you may
have an inflow problem from a- surface- water diversion or the-- may be seepage into the
lagoon from the surrounding land_
Lagoon- Operation .S
Startup •
1. Immediately after consauction establish a comvlete sod cover on bare soil
surfaces to avoid erosion.
2. Fill new lagoon design•treatment volume at leas half full of wat­6effore
waste loading berms, 'tal ng cafe' not to, erode lining or bans, slopes.
3. Dr2inaines into the boon shatild have a flexible wive extender on the
end of the pipe to discharge clear the bottom of tulle Lagoon during, initial
n.i]ing or another'me2ns 'of slowing- the incoming water to avoid erosion of
the litung•
4: - Wheii possible; bed ti loading new li000ns in, the spring to maxim
'bacterial estabiishment•(due to warmer weather).
;.. , _ _
5. It is recommended that a new lagoon be seeded with sludge from a hmifay
working swine lajooa in the,amount'of 0:S pe ce.-it of the fulL lagoon
iiatiid volume."!This sera,ing should'. oc bur at least two w� prior to the
acmdon of wastewater...
6. Mainmin a periodic check on the lagoon liquid pH. If the pH falls below
7.0, add a--.;dcuifivai lime at the•rare of T pound per 1000 cubic fee.* of
lagoon liquid volume until the pH rises -above 7.0. Optimum lagoon linuid
pH is between 7.5 and 8.0.
7. A dark color, lack of bubbling,,and excessive odor signals inadequa
biological activity: -.Consultation with. a technical serialist is recommended
if these conditions occur, r'or'prolohged periods, especially during the warm
season...
Loa 5• . :A .,
The more frecuently and reouha ly'tliat wastewv t is "added •to a lagoon, the better the
lagoon will function. Flush systerzis that wash'wa_ste"into the lagoon several times daily are
Optimum for treaanent. Pit reriiar;e systems, in which•one or more buildings are draine&
and recharged each day, also work well.' .

j r. 'i 3S d'�; •r i!�r ' .'"' ^'Y',z:r rzl r';7`,'f+�
.jfc
rM ,e�-,C—? Tr S
Practice water conservation—rrnianirid= building wares usage and
spiiine mom Ieaking waterers, broken pipes and washdown through
proper maimmnan= and wares conservation.
Ad nitnize feed was ge and spillage by loping feeders adjusted_ This
will reduce the amount of solids entering the lagoon
Mb
_ Maintain lagoon liquid level between ; the permanent storage level and
the full temporary storage' level., '
Place visible marlce-s or stakes on the lagoon bank to show the
minimum liquid level and -the-'makimum liquid lever (Figure 2-I).
Start irrigating at the, ear i st possible date in the spring based on
nutrient reauiremenrs and soil moisture so that'tempotary storage
will be miiimizad.for the 'summer, thunderstorm on. ' Sirniiariy,
gaze iii the late summer/early.;fall to,provide maximum lagoon
storage for the wing'.
The,la;oon liquid Ievel should river be.cioser than I foot to the Iowea
point or the dam or'e:nbznlainerit.
Do not Dump the lagoon I'auid level lower than the permanent storage
level unless you are removing sludge. V
r,ocaT float puma into Kris approximately I8 inches und::neath the liquid
siu� and aslar away from the draiu_niue'iinles as possible.
Prevent additions of 'bedding matrriais,' long-ste:araed forage orvegemtion,
molded feed; plastic_sV=" ges;.:or..bther.foreign.ma=ials into the lagoon-
rreauently remove -solidi rrom-'catch basins ai end of confinement houses or
wh'•ever they are�isralled.' -�':'
Maintain strict vegetation, rodent;; and .varmint control near lagoon edges.
Do not allow tre 'or large busies to grow on 3agoon dam or embanlrment
Remove sludge from the lagoon esther when the'sludge storage capacity is
full or before it,fnlls: peircent of{the permanent storage volume. 4
If animal production+alto be teriminate"d, the owner is responsible for
obtaining and amplemeatung a closure P,. to eliMinatr the possibility of a
pollutant cii r `
.<
dls ar�exu � Y sir 't ' � r � .�, r• ^� ri ��
Sludge Rr=oval: '
Raze of lagoon sludge buildup can be reduced by:

3«!e= S n :rFa'`{ _ ''�Y�lj`fr�` fisYir`> sr;sue
�t
k!•, i''r5(,'i+^�' . T'{t:'Yc .,fay'{�
F - s,.i' .(`{ �• ,<i fr' ' �. 'i 'S id . 3� r3 yp. i ,, { F"r'" fh4 , _• •tyy�r r-r .L •s j�,i� r
%1r 1- -# � - � i _ SY NLF ��,},=MiA• � }�tl,• r r�.ij3'�tt{+�i' ii>i��� �r � S 'l _y�. }� iLq� • S i i � � .
�t •, tt e' - - / }r'o �ir•�' �. 4y, .:�� �d �*%f. •�.d a :k. ♦ P, �� - • y ., ^;;.
• _ 'tie.. •f 3_ !•
_, ) J fs, 5 7 '.'F S .i lr y. 1 ,#�- s •-n t j i• € ? f
l f r r
. proper lagoon' sizing, !� ,
m harucai solids scnaradon or flusire:i' waste.
Qrvity settling of flushed waste solids.in an'appropriately designed basin, or
Minimizing feed wzs-.ge and spillage:
' L noon sludge that is removed annually rathe;� than''stored Ion, tE=, will: ,
l
have more numents,;
have more -odor,' and
require more land'to properly,'use the`nutiienrs. `
Removal
Yd".'7T7ff11��
Hire a custom applicator.
NEX the sludg6 is d loon lirruid with' a chopver=a.��irator impell= s
-Dump through` laiiie=Pore spr4i ere irrigaron system onto nearby �Dland;
and solliin'5 r ralB x , 5i ,, t
Dewater the utiner parr of lagoon by irrigation onto nearby cropland or
mragelana; mix r�,..mairiing sludge; purzip into lioriid sludge applicator, haul
and spread onto'cropiand on forageiand; and soil jncomorate.
Dekater the 'uDDer _parr O lagoon', pv irrigation"OirED nearby CIopland or
forazeland; dredge sludge From lagoon with aline or slud;e�barge; b
an area beside lagoon to receive the sludge�io ti= liquids can drain back
into lagoon; allow *sludge to dewater-,, haul and spread with manure spreader
onto cropiand or�ior2pland; and, soil-incorvorzre.
Regardless of the method, yoti mui have the`siudi,e`material analyzed for waste
const - n - ns just as you would ourlagoon, wit T - The'sludge will contain different
nutrieat and mewl values from the licuia° "The azrolicition of rhe'sludge to fields wM-be
limited by these nutrients, as ;well -as any, previous Waste' apnlications'to that field and mop
requirement Wa= applicarion rases wM be" discussed ]n. demu. in Chapter 3.
When namable; sludge, you must also''pa}►;atiention tortlYe liner to prevent damage. Qose
attention by the pumper or drag-line'on=:ator will a tsu=e thai the lagoon liner remains
intact If you see soil material or the' synthetic: liner r'nateiial being disturbed, you should
stop the acivity immediately and -not resume=until you are •sum that the sludge can be
removed without liner injury. If the diner is damaged itmust be repaired as soon as
posst�ie_
• t �.- {l T: '-r a iy `.3 err =' � . �' >s - i'
Sludge removed from the lagoon bias a.much higher-nhosphoriTs and. heavy metal content
than liquid. Because of this it shouldprvoaI y. be` pplied"to laud with low phosphorus :
and metal levers. as indicaied'hy a"' oil'test,-and'inrarporated to reduce the chance or
erosion_ Note that if the sludge is`applied to Belds th`very high soil -test SD Ores, it 4
should be applied only ar rases:eaualtto`.the'crop removal' or,pnosahorus.' As with ocher :
wastes, always have, �orueu edyf;nZt value • -
, ,i
The application or sludge will u%cr-...se the amo_urit or odor at the waste application site_
Extra precaution should be used io'observe the wind-,a&=tion and other conditions which
could increase the concern of neighbors.
,. �+ _py y. >�•t.t`�, •het r gp -•�..v 4�t�r�°«C s,yR�tY .�'' 4 F .

75
Z-
L W,
A.
Possible Causes of Lagoon F�iW6e
Loon L3flu= -result hi'the u=Btimed disciaa e' 6f 'wastem-ramr from 'the =cvlry-- TyD=
of failures include leakage thmuga the bottom. br side4"Ovempping, and breach of the
dam- AssmninAssuming_;=p and construction; 'ter
proper design h"' 0 owner has the responsibility for
..
y-Iead.,tb lagpon-failures include:
Moffi&afiodof the Oon S===e—an example is the pl===t of a - vim
in the dam VA -tout gnzrid cons==on. '-,(Cons&,an in
lagoon design;before plaLzng any p4= m dam
%
Lopn liq'u;id]evejs 1#gh lev&Is;:iim! -a safety, risk 77
3L
Failure to.*# tp�and maintain tie dam.
-4 4 '
Excess surface W" =-=':'flowiag iirtb th6 lagoon.
'Una integnty,�7pTqtpct ftorn. i6lir p�e, scouT.7m c,,, damage dining sludge
removal, or i�a' 16_'Ve�g lac,,c>on Bqudd level below gomidwater
IMM
y.
.P
table.
A
NOTE: Ulaggoon water is allosve3 to' overtop -'the dam,the moving ve"aterwiJI soon cmse
gullies to form in the dam. Ofiai'this zts,`it 6im-'qiiicJdy-,cause a large discharge
of WasmWat.— and possiblemr_ ple da�mhiU
Ir j
(4'
K
-9 --;­
z
k-A 4
144 1 10
n.
:4
tit A
41"
4
q4;%
r;i.f r
71,
4,
V,Jt 4! A-

ANIMAL WASTE UTILIZATION PLAN
Producer: MURPHY SMITH
Location: 19829 NC 131 S.
BLADENBORO NC 28320
Telephone: [phone]
Type Operation: Existing Feeder to Finish Swine
Number of Animals: 2448.00 hogs
(Design Capacity)
STORAGE STRUCTURE: Anaerobic Waste Treatment Lagoon
APPLICATION METHOD: Irrigation
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops
in the fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown
and the nutrient content of the waste. Do not apply more
nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall be applied to land eroding at less than
5 tons per acre per year. Waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on saturated soils, when it is raining, or
when the surface is frozen. Either of these conditions may
result in runoff to surface waters which is not allowed
under DWQ regulations.
Page: 1

ANIMAL WASTE UTILIZATION PLAN
5. Wind conditions should also be considered to avoid drift and
downwind odor problems.
6. To maximize the value of the nutrients for crop production
and to reduce the potential -for pollution, the waste should
be applied to a growing crop or applied not more than 30
days prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. If
you choose to change methods in the future, you need to revise this
plan. Nutrient levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from your
waste management facility. In some cases you may want to have plant
analysis made, which could allow additional waste to be applied.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
This waste utilization plan, - if carried out, meets .the requirements
for compliance with 15A NCAC 2H .0217 adopted by the Environmental
Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
2448 hogs x 1.9 tons waste/hogs/year = 4651.2 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
2448 hogs x 2.3 lbs PAN/hogs/year = 5630.4 lbs. PAN/year
Applying the above amount of waste is a big job. You should plan
time and have appropriate equipment to apply the waste in a timely
manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
Page: 2

. 5
5 -
ANIMAL WASTE UTILIZATION PLAN
TABLE 1: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & CLASS--
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N.
PER AC
AC
USED
----
or
------
APPLY
RESID.
APPLIC
METH
N
TIME
2589
1
EXA
C
125.0
141.25
15
10
1412.5
I
MAR-JUN
2589
12
[NA
2589
3
1 NA
2589
1-1
JEXA
2589
1
EXA
2589
1-2
NA
2589
1-2
1 NA
2589
--3
1 NA
2589
--3 INA
END
12Q
I
I
1135
115
112
1162
MAR0-JUN
C
120
2700
I1_20
1135
115
MAR-JUN
W
60
144
0
10
1440
I
I
I
I
I
OCT-MAR
SB
30
0
1200
I
1120
1
11.0
IAPR-�4UN
W
60
144
0
I
I
I
112
11728
OCT-MAR
SB
30
120
0
I
I
I
112
11440
APR-JUN
W
60
144
0
1
1
120
12880
OCT-MAR
SB
25
1
100
1
0
120-
12000
I
APR-JUN
TOTAL116420.5
-- -- indicates that this field is being overseeded (i.e.
interplanted) or winter annuals follow summer annuals.
NOTE: The applicator is cautioned that P and K may be over applied while
meeting the N requirements. In the future, regulations may
Page: 3

ANIMAL WASTE UTILIZATION PLAN
require farmers in some parts of North Carolina to have a
nutrient management plan that addresses all nutrients. This
plan only addresses nitrogen.
9
Page: 4

ANIMAL WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERMS LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
See required specification 2.)
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
--------
APPLY
RESID.
APPLIC
METH
N
TIME
END
TOTAL10
-- Indicates that this field is being overseeded (i.e. interplanted) or
winter annuals follow summer annuals.
** Acreage figures may exceed total acreage in fields due to
overseeding.
* lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and 2 above:
CROP CODE
CROP
UNITS
PER UNIT
C
CORN
BUSHELS
1.25
SB
SOYBEANS
BUSHELS
4
W
WHEAT
2.4
TOTALS FROM TABLES 1 AND 2
ACRES LBS AW N USED
Page: 5

ANIMAL WASTE
UTILIZATION PLAN
�cc V, M.
TABLE 1
42
TABLE 2
0
0
TOTAL
42
* * * BALANCE
*** This number
must be less than
or equal
to 0 in order to
fully
utilize the animal waste N
produced.
6

ANINAL WASTE UTILIZATION PLAN
*** This number must be less than or.equal to 0 in order to fully
utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffers, filter strips along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than
the acres shown in the tables.
See attached map showing the fields to be used for the utilization of
animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be -nutrient
rich and will require precautionary measures to prevent over application
of nutrients or other elements. Your production facility will produce
approximately 905.76 pounds of plant available nitrogen per year in the
sludge.
If you remove the sludge every 5 years, you will have approximately 4528.8
pounds of PAN to utilize. Assuming you apply this PAN to hybrid
bermudagrass hayland at the rate of 300 pounds of nitrogen per acre, you
will need 15.096 acres of land. If you apply the sludge to corn at
the rate of 125 pounds of nitrogen per acre, you will need 36.2304 acres
of land. Please be aware that these are only estimates of the PAN and
land needed. Actual requirements could vary by 25% depending on your
sludge waste analysis, soil types, realistic yields, and application
methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the
soil at the time of irrigation such that runoff or ponding occurs. This
rate is limited by initial soil Aoisture content, soil structure, soil
texture, water droplet size, and organic solids. The application amount
should not exceed the available water holding capacity of the soil at the
time of irrigation nor should the plant available nitrogen applied exceed
the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables 1 and 2. Failure to apply the recommended rates and
Page: 7

ANIMAL WASTE UTILIZATION PLAN
amounts. of nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application
rates and amounts.
�
I
Tract
I I
I Field I
I I
Soil Type
2589
[ 1 [
EXA.
2589
I I
[ 2 [
NA
2589
I I
13 [
NA
2589
1 �
[ --1 [
EXA
2589 [
I I
--1 [
EXA
I
2589 I
I
--2 [
NA
2589 1
--2 I
NA
1
2589 [
I
--3 [
NA
[
2589 [
i
I
--3 [
1
NA
crop
I C
Application RatelApplic. Amount
I (in/hr) (inches)
I I
[ 0.35 [ *0.75
I 1
[ C
[ 0.4
[ *0.75
I C
1 *0.75
[ 0.4
[ *0.75
[ SB
[ 0.35
I
I
I
[ *0.75
I W
[ 0.5
I
I
SB
[ 0.35
I *0.75
I
I
I
I *0.75
�
I W
I
[ 0.5
I
*0.75
*0.75
Page: 8

ANIMAL WASTE UTILIZATION PLAN
* This is the maximum application, amount allowed for the soil
assuming the amount of nitrogen allowed -for the crop is not over
applied. In many situations, the application amount shown cannot
be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180.00 days of temporary storage and
the temporary storage must be removed on the average of once every
6.00 months. In no instance should the volume of the waste be stored
in your structure be within the 25 year 24 hour storm storage or one
foot of freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply the
correct rates to the acres shown in Tables 1 and 2. Failure to apply
the recommended rates and amounts of nitrogen shown in the.tables may
make this plan invalid.
Call your technical specialist after you receive the waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate.prior to applying the waste.
NARRATIVE OF OPERATION
0..,E L 5 q L V �G ✓i
L t h
u G io
JJ e-+ J� U ('A ut'e- 45S 4 vtin �
/
P
C-L>w, C"L �
_
a- 1 L� o� C I-C-1
a, L r- L
Ya(a �� •.
r +^ J0A
t-� W lt�J b o y a �s
tiv4r- `�
j
�`�'Z-
c-ov t m r- - e. [ u r �� 1 7.LL lT'n.
9
h LA,-- te- I
Page: 9

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the. owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
5. odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be considered.
Page: 10

1
WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet -to
wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly into water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
the site. -
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 11

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
18. If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed -to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22. Waste shall be tested within 50 days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate — determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when these
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept.for five years. Poultry dry
waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be
maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North
Carolina regulations.
Page: 12

ANIMAL WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm:S & S FARMS
Owner/Manager Agreement
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
North Carolina Division of Water Quality (NCDWQ) before the new
animals are stocked. I (we) also understand that there must be no
discharge of animal waste from this system to surface waters of the
state from a storm event less severe than the 25-year, 24-hour
storm. The approved plan will be filed on -site at the farm office
and at the office of the local Soil and Water Conservation District
and will be available for review by NCDWQ upon request.
Name of Facility Owner: MURPHY SMITH
(Please print)
Signature: Date: % 0 - 7 -- 1?7
Name of Manager(If different from owner):
signature: Date:
Name of Person Preparing Plan: (Please print)Samuel G. Warren
Affiliation:USDA- NRCS - Phone No. 910-862-6936
Address (Agency): 122 Ag. Service Ctr.
Elizabethtown NC 28337
Signature: _�� Date: !D l
Page: 13

Mortality Manaclement Methods
(check: which mcthod(s) arc being implemented)
J Burial three Sect beneath the surface of the around within 24 hours after
knowledze of the death. The burial must be at least 300 feet from an,,, Bowing
stream or public body of water. -
,�SI Rendering at a rendc,in2 plant licensed undo: G.S. 106-163.7
Q Complete incincration
In the case of dead poultry only, placing in a disposal pit of a size and design
approved by the Department of Aariculturc
Cw Any method which in the professional opinion of the State Ve:crinarian would
make possible the salvage of part of a dead animal's value without endangering
human or animal health. (Written approval of the State Veterinarian must be
attached)
Insect Control Checklist for Animal Operations
Source Cuusc RM1's to Control bisects 5ili SpCeirc Practices
Liquid Syslcnls
Flu:il GMICC4 Accunuilation of solids flush syslcnl is designed and operated
suflicicnlly to remove accuawlated solids rrom
Water!; as designed.
I(Clilove bridging of acclllaulatcfl solids ill
{{{ IIISLIIar}�'C
l.aUoons and Pils Crusted Solids Maintllill lagoaus, scnliilg basins and hits MICA:
pest brcxding is apparcnl to lllininlize the
crusting of solids to a &plh of no iuoru than G -
a inches over more khan 30% of surface.
1:aecs�iv� Ve6clalive Decaying vegetation Maintain vCgCtulivc control along hanks of
t;iultlli lagoons and other inlponodmunts to preveal
acculmulaiion of decaying vegetative mailer
along Watees edge on Impoundment's perimeter.

I �1
Swine Farm Waste Management Odor Control Checklist
Suul'cc Cuusc I1MI's to N11111ulice 0dur' Site Specific III -:dices
Fal rllsteud Swine production f- Vegetative or wooded buffers;
Itccou►mended best managcnicat practices;
Good judgment and common sense
Animal bully surfaces Dirly manure -covered annuals
0
Dry floors
Flour Stu Caec:, Wei nl:uull'c-euvercd pool's
A
Stoned floors; F,
Waterers located over slotted floors;
Feeders at high end of solid floors;
x
scrape manure buildup from floors;
Cl
Underfloor ventilation for drying
KLI11111-e euliccliun pits • Urine;
> (
I-regUent ►uanure removal by Ilush, pit recharge,
• `Partial microbial deconlpositioll
or scrape;
Underfloor vcnlilatiun
Ventil,ltiaru exhaust f:llls 0 Volatile gases; .. Fan ulainten:ulee;
Dust
C1
Isfficient air movemcm
lluluur surf,lccs
Dust
MISIRIOW11 IMWIXll groups Uf anilUals;
1'cccl addilivcs;
0
Fucder covers;
i5K
Feed delivery downspout extenders lu !ceder
Covers
l lmh t:lnla
Agilalion of recycled lagoon
C1
flush lank covers;
liquid while tanks arc filling
❑
Exiend fill lines to near bottom of tanks with
anli-siphon vents
blush alkys
Agimiun during wastewater
CI
Underfloor flash with underfloor venlilation
conveyance
Pil lech;uge poiuls 0
Agilaliun ofrecycled lagoon
n
I:xlellll recharge lines lu near 1x1110nl offlits
liclilid While pits are filling
with anti-siplunl veins
Lift lIillioIIs •
A8iwllun (1111-hig Slllllf) ISUIk
Cl
Stimp timk covers
N
filling and drawdown
nulsill,: drain cullcctiuti
Al;italiou during wasitnuler
n-
hox covers
1}r juuetiull huxcs
conveyance
AI►•1U(: - I• ounitivr 11. 1996, Page 3

Source
. Cause -
HMI's to Minimize Odor site Specific Practices
Gill of drainpipes al
• Agitation during wastewater
M
Exlead discharge point of pipes underneath
lagoon
couvcyancC
lagoon liquid level
Lagoon surfaces
0 Volatile gas cuiissiolls;
IN
Proper lagoon liquid capacity;
• lliological mixing;
1:�
Correct lagoon startup procedures;
Agilalioil
C
Minimum surface arcs -to -volume ratio;
Minimum agitation when.pumping;
Cl
Mechanical aeration;
D
Proven biological additives
lri it;llliull sprinkler
• 1ligh prCsstlte agitation;
Irrigate on dry days with Iittic or no wind;
nuzzles
0 Wind drift
Cl
Minimum recommendcd.operatiag pressnre;
%I
Pump imakehear lagoon liquid surface;
Pump from second -stage lagoon
Swrage Umk or b:lsin a Partial microbial decomposition; M Room or midlevel loading;
�nrl'aee Mixing while filling; CI 'Tank covers,
• Agitation when emplying Cl Basin surface mats of solids;
Cl Proven biological additives or oxidants
SClllilig basin surface •
Partial microbial dceompositioll;
M
Exteod drainpipe outlets undernealh litillid
`
Mixing while filling;
level;
}1'L
t
AJ;iialion when emptying
Cl
ltcniove sctfled solids regularly
Manure, slurry orsludgc •
Agitation when spreading;
Cl
Soil bljecdon of slurry/sludges;
spic;nler outlets `
Volatile gas emissiolls
❑
Wash residual manure from spreader after usc;
f�
17-1
Proven biological w1dilives or oxitlarits
thicovered mannrc, •
Volatile gas C111iS$iUI15 While
0
Soil injection oI'slurrylsludgcs
slurry or silidue on field
drying
0
Soil incorporation within 48 brs.;
Silrliiee5
`.
0
Spread in shin uniform layers fur rapid {crying;
Cl
Proven biological additives, or oxidants
lhad animals
Carcass decomposition
proper disposition of carcasses
Dead animal disposal
Carcass decomposition
M
Complete covering of carcasses in burial piis;
pits `
©
Proper location/construction ofdisposal pits
hicilml-wars � 14/ • incomplete cumbusliotl 17 Secondary slack burners
AMOC - November 11, 1996, Page 4

Som-Ce - - Cause WIN In Miniini%C Odor Site Specific PI-:telices ' - -
Standing water aruund a Intproper draiitaUc; , , Grade and landscape; such Ihat water drains
facilities & Microbial decomposition of away from -facilities
organic matter
Manure trackeil onto 0 Poorly maintained access roads J0- f ann acecss road inaintenance
public roads firom farm
acecss
Additional Information : Available From :
Swiiie Manure Management ; 0200 ItulelilMP Packet NCSIJ, County Extension Center
Seville 1'ruductiun Varm I'uienlial Odor Sources and Remedies ; EIIAL Fact Slicct NCSIJ - 11AIi
Swine: Production facility Manure Manage nicnt: Pit Recharge - Lagoon Treatment ; RBAG 128-88 NCSU - IIA li
Swine Production facility Manure Management: underfloor Flush - Lagoon Treamient ; EBAR 129-88 NCSIJ - IIAI:
Lagoon Design and Mauagenlent for Livestock Manure Treatment and Storage ; EIIAF 103-83 NCSU - I IAl'
Calibration of Manure: and Wastewater Application Equipment ; GBAG fact Sheet NCSIJ - IIAIi
Controlling Odors from Swine Buildings ; 11111-33 NCSIJ - Swine Extension
Environmental Assurance Progragt ; NI'PC Manual NC fork Prodticers Assoc
Options for Nlaual'ing Odor; a report from Ilic Swine Odor Task force NCSIJ Agri Communications
Nuisance Concerns in Animal Manure Management: Odors and flies ', PRO 107, 1995 Conference Proceedings Florida Cuopereuivc INICIISiOli
AMOC- November H. 1996, Page:5

_ "
EMERGENCY ACTION -PLAN
PHONE NUMBERS
DWQ 910-486-1541
EMERGENCY MANAGEMENT SYSTEM 911
SWCD 910-862-6936
NRCS '910-862-6936
1
This plan will be implemented in the event that wastes from
your operation are leaking, overflowing, or running off
site.- You should not wait until wastes reach surface waters
or leave your property to consider that you have a problem.
You should make every effort to.ensure that this does not
happen. This plan should be posted in an accessible
location for all employees at the facility. The following
are some action items you should take.
1. Stop the release of wastes. Depending on the
situation, this may or may not be possible. suggested
responses to some possible problems are listed below.
A. Lagoon overflow -possible solutions are:
a.
Add
soil to berm to increase
elevation of dam.
b.
Pump
wastes to fields at an
acceptable rate.
C.
Stop
all flows to the lagoon
immediately.
d.
Call
a pumping contractor.
e.
Make
sure no surface water is
entering lagoon.
B: Runoff from waste application field -actions
include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
C. Incorporate waste to reduce runoff.-
d. Evaluate and eliminate the reason(s) that
caused the runoff_
e. Evaluate the application rates for the fields '
where runoff occurred.
C: Leakage from the waste pipes and sprinklers --action
include:
a. Stop recycle pump.
b. Stop irrigation pump.
C. Close valves to eliminate further discharge.

d. Repair all leaks prior to restarting pumps. `
D: Leakage from flush systems, houses, solid
separators -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure no siphon occurs.
d. Stop all flows in the house, flush systems, or
solid separators.
e. Repair all leaks prior to restarting pumps.
E: Leakage from base or sidewall of lagoon. Often
this is seepage as opposed to flowing leaks- "
possible action:
a. Dig a small well or ditch to catch all seepage,
put in a submersible pump, and pump back to
lagoon.
b. If holes are caused by burrowing animals, trap
or remove animals and fill holes and compact_
with a clay type soil.
c. Have a professional evaluate the condition of
the side walls and lagoon bottom as soon as
possible.
2. Assess the extent of the spill and note any obvious
damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what
duration?
C. Any damage noted, such as employee injury, fish
kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface
waters?
f. Could a future rain event cause the spill to reach
surface waters.
g. Are potable water wells in danger (either on or off
of the property) ?
h. How much reached surface waters?
3: contact appropriate agencies.
a. During normal business hours, call your DWQ
(Division of Water Quality) regional office; Phone
910-486-1541• After hours, emergency number: 919-
733-3942. Your phone call should include: your
name, facility, telephone number, the details of

the incident from item 2 --above, the exact location
of the facility, the location or direction of
movement of the spill, weather and wind conditions.
The corrective measures that have been under taken,
and the seriousness of the situation.
b. if spill leaves property or enters surface waters,
call local EMS Phone number 911-.
C. Instruct EMS to contact local Health Department.
d. Contact CES, phone number 910-862-4591, local ShCD
office phone number 910-862--6936, and local NRCS
office for advice/technical assistance phone number
.910-862-6936_
4: if none of the above works call 911 or the Sheriff's
Department acid explain your problem to theta and ask
that person to contact the proper agencies for you,
5: Contact the contractor of your choice to begin repair
of problem to nininize off -site damage.
a. Contractors Name: -se-
b. Contractors Address:
C. Contractors Phone:`
6: Contact the technical specialist who certified the
lagoon (NRCS, Consulting Engineer, etc.)
a. Name: >Ar ti
b. Phone: 6136
7: Implement procedures as advised by D➢7Q and technical
assistance agencies to rectify the damage, repair the
system, and reassess the waste management plan to keep
problems with release of wastes from happening again.
d�ud�ln..Nwordlem qec tpt�n-2u
��pt 12,96

I

PAP F DFir
M�a. 4Ac a,be
... 171,11L
c r•
[AOUSC AXA*rtJ _2 4AWO x'NZippTbP W0f6v5JaaS �!
S+V i1 uG �r—s x
E d1✓E.tlrlo+v .
,.. PIP • ejvT[tr
. X•NrG- HLY-
t
r
Cr.i.l9t L�AC�e'.O-fi+1..: en09Xt 6,,.,'�:�fS
r�•�_.,../.w':7w Rcld4sert 7-.fi�c- '.C- Q-t4 110,04d'"T-
r I.AGrooN Silt~ 7b 8g "sMPA040 ! �roGk-Pic+ �M" TGP5o��)
�NA WS&o 7b CAP ZrAE. rv*O Ou7's/GE SCApft, TWa/OE j/opts
fcnr+ M? 7b PiPLF a-TA,-T' 4-LeYf7104 6A1L4, 51" .640pws 2-8 `.
7'h)4 em`l9MMI.,46 AvEA"CS 300 --SOo C,aat4 gA-kQi tN e&-CSS
OF 3PdOlViM � OST,M4rMS. .
.- .DiK.G._ vo., ae.' okjc7r piLs..L& $,i iov7e. 74eG DS)
"3 :L �wsiD6
•�/LC M4-rUlz14-L;
- st�fl t R,,t.. _ .. _ .' - �i ►LTIA7ll3 t? flR[sA•S C...L?Lr Ac�tes� A*+ Fa N 0ws
— UMW . ire) t__ Z:S- -Trtq
— pe-corl"Zz a (10-io-ao) _ _ I Z i0 -L%s,
'bWK P*A%E ON un,%wl 9464' ARARS -ro Ph@PAltE_ . 3-tf "_ sEcnBa al
Se;Cp .SY...;5ECOIAJ4 9*7ZE•S 'evr77V;
ZEAMubrl OOAVU,M "-JSA - AjWi A g L8S• ++
�. 13"I f} - M"411 - -TUL,{
Faume - scrr-,vov, mAimi3-r-u4: - _ dgo ILa.s.
'ff,*k cRMLy dvveA -- AYCC.,yFss 6,� 41S S. C$N1T* QLC- A4..77mi S o7wat :7-N" �ool;J6 .
`top 1") CLIL-nPMV- U-MS. 2r= -"SE-DJ )MC-+4' '70',- ,BE. 90VOISM+L1O
MULr-9 w I -TU SIvAw 7V o4 ro/w) �Q� A)he +f DaT -3 ARRJ ✓E . ib P6+c/17A,�6r�] tMSI55.1
SD -7 5 % ISAO.40 G s vC_ _ /• 1 �$5. MULGi� +1
C Rt r, P STRMAJ w' b,4tV GW, s'nt• 1 Nd 7"
/Wes:
�e'l Bo'Irtsrh . �IeV.'
8440" CO, — NDT 'Ta xC*CL'' -
S"el .. Ir.Art.rW
D

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
October 1, 2004
Murphy Smith
Double S Farm
19829 Hwy 131 South
Bladenboro NC 28320
Alan W. Klimek, P. E., Director
Division of Water Quality
RECEIVED
OCT 15 2004
DEW -FAYEiiEVILLE REGIONAL OFRCE
Subject: Certificate of Coverage No. AWS090082
Double S Farm
Swine Waste Collection, Treatment,
Storage and Application System
Bladen County
Dear Murphy Smith:
On June 11, 2004, the North Carolina Division of Water Quality (Division) issued a revised State General
Permit for swine facilities. The General Permit was issued in accordance with the directive of Senate Bill
733 (Session Law 2003-28).
In accordance with your application received on March 4, 2003 and in accordance with the directive of
Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to Murphy
Smith, authorizing the operation of the subject animal waste collection, treatment, storage and land
application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AW S090082 which expires October 1, 2004.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Double S Farm, located in Bladen County, with an animal capacity of no greater
than an annual average of 2448 Feeder to Finish swine and the application to land as specified in the
facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or Farrow to
Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary, they may
be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a rate of 4
gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Since this is a revised State
General Permit, it contains new requirements in addition to most of the conditions contained in the
previous State General Permit. Enclosed for your convenience is a package containing the new and
revised forms used for record keeping and reporting. Please pay careful attention to the record ke in
and monitoring conditions in this permit.
Aquifer Protection Section - Animal Feeding Operations Unit
1636 Mail Service Center, Raleigh, Forth Carolina 27699-1638
Phone: [phone] ! FAX: [phone] Internet: h2o.enr.state.nc.us
An Equal Opportunity/Affirmative Action Employer — 50% Recycled/10% Post Consumer Paper
NorthCaroiina
,lVaturaMy

If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (Iocal, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 2H .0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100 foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Duane Leith at (919) 7I5-6186.
Sincerely,
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
Fayetteville Regional Office, Aquifer Protection Section
Bladen County Health Department
Bladen County Soil and Water Conservation District
Permit File AWS090082
APS Central Files

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P. E., Director
Division of Water Quality
May 1, 2003
Murphy Smith
Double S Farm
19829 Hwy 131 South
Bladenboro NC 28320
Subject: Certificate of Coverage No. AWS090082
Double S Farm
Swine Waste Collection, Treatment,
Storage and Application System
Bladen County
Dear Murphy Smith:
On April 28, 2003, .the North Carolina General Assembly ratified Senate Bill 733 which directs the
Division of Water Quality (Division) to extend the expiration date of the Swine Waste Operation General
Permit AWG100000. Therefore, the General Permit has been re -issued by the Division to extend the
expiration date to October 1, 2004. During the period of this extension the Division will be working with
all interested parties on the development of a new version of the Non -Discharge General Permit.
In accordance with your application received on March 4, 2003 and in accordance with the directive of
Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to Murphy
Smith, authorizing the operation of the subject animal waste collection, treatment, storage and land
application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AWS090082 which expired on April 30, 2003.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Double S Farm, located in Bladen County, with an animal capacity of no greater
than an annual average of 2448 Feeder to Finish swine and the application to land as specified in the
facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or Farrow to
Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary, they may
be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a rate of 4
gilts for every 3 sows
The COC shall be effective from the date of issuance until October 1, 2004. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
ARA
AME R
Non -Discharge Permitting Unit Internet httpJ/h2o.enr.state.nc.us/ndpu
1617 Mail Service Center, Raleigh, NC 27699-1617 Telephone [phone] Fax [phone]
Customer Service Center Telephone [phone]
An Equal Opportunity Action Employer 50% recycled/10% post -consumer paper

Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per NRCS standards a 100 foot separation shall be maintained between water supply wells and any
lagoon or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any pans, requirements, or Iimitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Sue Homewood at [phone] ext. 502.
Sincerely,
lzdel-
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
Fayetteville Regional Office, Water Quality Section
Bladen County Health Department
Bladen County Soil and Water Conservation District
Permit File AWS090082
NDPU Files

40
ANIMAL WASTE UTILIZATION PLAN
v
Producer: MURPHY SMITH
Location: 19829 NC 131 S.
BLADENBORO NC 28320
Telephone: [phone]
Type Operation: Existing Feeder to Finish swine
Number of Animals: 2448.00 hogs
(Design Capacity)
STORAGE STRUCTURE: Anaerobic Waste Treatment Lagoon
APPLICATION METHOD: Irrigation
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops
in the fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
1. Always -apply waste based on the needs of the crop to be grown
and the nutrient content of the waste. Do not apply more
nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall be applied to land eroding at less than
5 tons per acre per year. waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on saturated soils, when it is raining, or
when the surface is frozen. Either of these conditions may
result in runoff to surface waters which is not allowed
under DWQ regulations.
Page: 1

ANIMAL WASTE UTILISATION PLAN
r
5. Wind conditions should also be considered to avoid drift and
downwind odor problems.
6. To maximize the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more than 30
days prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. If
you choose to change methods in the future, you need to revise this
plan. Nutrient levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from your
waste management facility. In some cases you may want to have plant
analysis made, which could allow additional waste to be applied.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
This waste utilization plan, if carried out, meets the requirements
for compliance with 15A NCAC 2H .0217 adopted by the Environmental
Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tans, etc.)
2448 hogs x 1.9 tons waste/hogs/year = 4651.2 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
2448 hogs x 2.3 lbs PAN/hogs/year = 5630.4 lbs. PAN/year
Applying the above amount of waste is a big job. You should plan
time and have appropriate equipment to apply the waste in a timely
manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
Page: 2

ANIMAL WASTE UTILIZATION PLAN
10
TABLE 1: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
-------
APPLY
RESID.
APPLIC
METH
N
TIME
12589
1
EXA
C
125.0
141.25
15
10
1412.5
I
MAR--JUN
2589
J
12
INA
II
1120
1135
115
I12 .
1MAR-J-UN1620
J 2589
3
1 NA
I C
11211
1135
115
120
12700
I
MAR-JUN
2589
EXA
0
1-1
IW
I
160
1144
110
11440
OCT-MAR
2589
--1
EXA
SB
30
120
0
10
1200
1
I
I
I
I
I
IAPR-JUN
2589
--2
0
INA
IW
I
1110
1144
112
11728
OCT-MAR
2589
SB
3$
0
1-2
INA
I
I �b
1120
112
11440
APR-JUN
2589
0
1-3
INA
IW
I
160
1144
120
12880
OCT--MAR
2589
SB
fl
1-3
INA
I
13��°
1100
120
12000
APR-JUN
END
I
TOTAL116420.5
-- Indicates that this field is being overseeded (i.e.
interplanted) or winter annuals follow summer annuals.
NOTE: The applicator is cautioned that P and K may be over applied while
meeting the N requirements. In the future, regulations may
Page: 3

ANIMAL WASTE UTILI2ATION PLAN
require farmers in some parts of North Carolina to have a
nutrient management plan that addresses all nutrients. This
plan only addresses nitrogen.
Page: 4

ANIMAL WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
See required specification 2.)
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
-------
APPLY
RESID.
APPLIC
METH
N
TIME
END
TOTAL 10
-- Indicates that this field is being overseeded (i.e. interplanted) or
winter annuals follow summer annuals.
** Acreage figures may exceed total acreage in fields due to
overseeding.
* lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and 2 above:
CROP CODE
CROP
UNITS
PER UNIT
C
CORN
BUSHELS
1.25
SB
SOYBEANS
BUSHELS
4
W
WHEAT
2.4
TOTALS FROM TABLES 1 AND 2
ACRES LBS AW N USED
Page: 5

ANIMAL WASTE UTILIZATION PLAN
TABLE 1 42
TABLE 2 0
TOTAL 42
*** BALANCE
a-6
t.Lc P
$330 I IC>
-2,ofl 1-5oSS I
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.
Page: 6

ANIMAL WASTE UTILIZATION PLAN
*** This number must be less than or equal to 0 in order to fully
utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffeKs, filter strips along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than
the acres shown in the tables.
See attached map showing the fields to be used for the utilization of.
animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient
rich and will require precautionary measures to prevent over application
of nutrients or other elements. Your production facility will produce
approximately 905.76 pounds of plant available nitrogen per year in the
sludge.
If you remove the sludge every 5 years, you will have approximately 4528.8
pounds of PAN to utilize. Assuming you apply this PAN to hybrid
bermudagrass hayland at the rate of 300 pounds of nitrogen per acre, you
will need 15.096 acres of land. If you apply the sludge to corn at
the rate of 125 pounds of nitrogen per acre, you will need 36.2304 acres
of land. Please be aware that these are only estimates of the PAN and
land needed. Actual requirements could vary by 25% depending on your
sludge waste analysis, soil types, realistic yields, and application
methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the
soil at the time of irrigation such that runoff or ponding occurs. This
rate is limited by initial soil moisture content, soil structure, soil
texture, water droplet size, and organic solids. The application amount
should not exceed the available water holding capacity of the soil at the
time of irrigation nor should the plant available nitrogen applied exceed
the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables 1 and 2. Failure to apply the recommended rates and
Page: 7

ANIMAL WASTE UTILIZATION PLAN
amounts of nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application
rates and amounts.
I I
I
lApplication
RatelApplic. Amount
Tract
l Field l
I I
Soil Type
l Crop
I
l (in/hr)
I
I (inches)
2589
11 [
EXA
( C
I 0.35
I *0.75
2589
I I
1 2 l
NA
I
l C
I
l 0.4
1
l *0.75
2589
I I
l 3 l
NA
I
l C
I
l 0.4
I
l *0.75
I
2589 l
I
-1 I
EXA
I
l SB
I
l 0.35
I
I *0.75
I
2589 l
1
-1 I
EXA
I
l W
I
i 0.5
I *0.75
I
2589 l
I
-2 l
NA
I
l SB
I
l 0.35
!
l *0.75
I
2589 I
I
-2 l
NA
[
I W
I
l 0.5
l *0.75
I
2589 I
I
-3 I
NA
I
I SB
I
0.4
I
I *0.75
I
2589 I
I
-3
NA
I
l W
I
0.5
I *0.75
Page: 8

ANIMAL WASTE UTILIZATION PLAN
r
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations, the application amount shown cannot
be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180.00 days of temporary storage and
the temporary storage must be removed on the average of once every
6.00 months. In no instance should the volume of the waste be stored
in your'structure be within the 25 year 24 hour storm storage or one
foot of freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply the
correct rates to the acres shown in Tables 1 and 2. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may
make this plan invalid.
Call your technical specialist after you receive the waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate prior to applying the waste.
NARRATIVE OF OPERATION l
t.►GLw10L9 W Y�P�L i.� � L \ +� a`�-'�� � rh wTt`� W �l,2cvQ" �50 �-c-G-�s .
Gt Gre' . Gw`"' ! Y&'-i1 Gu�C 504
Fj ;jct, c""' 6,- %A L" r- a,li�, -5c --k- -._� '[ vK A. t/- r— [ fa. l Tyr 't` ` !
cc-r." 41-� 1WL1t4-- h LJ
Page: 9

WASTE UTILIZATION PLAN
V
REQUIRED SPSCIFICA IONS
1. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
5. Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be considered.
Page: 10

WASTE DTILIBATION PLAN
REQUIRED SPECIFICATION
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1', 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to
wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly into water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
the site.
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 11

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
18. If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal.waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22_ Waste shall be tested within 60 days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when these
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
years. Waste application records for all other waste -shall be
maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North
Carolina regulations.
Page; 12

ANIMAL WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm:S & S FARMS
Owner/Manager Agreement
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
North Carolina Division of Water Quality (NCDWQ) before the new
animals are stocked. I (we) also understand that there must be no
discharge of animal waste from this system to surface waters of the
state from a storm event less severe than the 25-year, 24-hour
storm. The approved plan will be filed on -site at the farm office
and at the office of the local Soil and Water Conservation District
and will be available for review by NCDWQ upon request.
Name of Facility Owner: MURPHY SMITH
(Please print)
signature: Date:
Name of Manager(If different from owner):
Signature: Date:
Name of Person Preparing Plan: (Please print)Samuel G. Warren
Affiliation:USDA-.MRCS Phone No. 910-862-6936
Address (Agency): 122 Ag. Service Ctr.
Elizabethtown NC 28337
signature: �j . �%�-, ;_� Date:
Page: 13

Source
rt:,�ltlNsll;QilllCfSk� �' r�.
\•lortality Manaoement Methods
(check- which method(s)'are being implemented)
U Burial three feet beneath the surface of the ground within 24 hours after
knowledge of the death. The burial must be at lust 300 feet from any flowing
stream or public bodv of water.
Rendering at a rendering plant licensed under G.S. 106-163.7
Complete incineration
C] In the case of dead poultry only, placing in a disposal pit of a size and' design
approved by the Depanment of Agriculture
G Anv method which in the professional opinion of the State Veterinarian would
make possible the salvage of -part of a dead animal's value without endangering
human or animal health. (Written approval of the State Veterinarian must be
attached)
Insect Control Checklist for Animal Operations
Cause 11MHs to Conivol Insects
IL Liquid Syslcins
,ost of solids Flush systcsn is dcsibned and operatcel
sufticicntly to remove accumulated solids rrnin
gutters as designed.
7- Remove bridging of accumulated solids of
dighargo
Sliano,lilts and fits Crusted Solids Maintain lu600sis, seltlisng basics and bits where
pest brecditng is apparent to minimize tlnc
crusling of solids to a depth of no snore than 6 -
8 inches over more than 30% of stlrfacc.
Excessive Vcgoalivc • Decaying vegclaliolt Maintain vegetative control along hanks of
i iruwth lagoons and other impoundments to preyed
accuantlatiou ordecaying vegetative: matter
along wrices edge oil impoundment's perime:lur.
Site Stiecirc Nraclices

Swine Farm Waste Management Odor Control Checklist
Sulircc Cause RNIPS to H4inludu Will. Site Specific Practices
hariusteall
Swine production
C�f-
Vegetative or wooded buffers;
Recommended best management practices;
,R1
Good judgment and couninon sense
A liimul 110dy SllrfUCS
• nirly manure -covered annuals
C1
Dry floors
l:ln4l1' wlrfiaces
• Wet taamire-Covered flool's
Slotted floors; �a r
ti
Waterers located over slotted noors;
t&
Feeders at high end of solid floors;
X
Scrape manure buildup from floors;
CI
Underfloor ventilation for drying
Mauuru collection pia
• Urille;
0
Frequent manure removal by ntisii, pit recharge,
• I'ailial microbial decomposilion or scrape;
0 Underfloor ventilation
Ventilation Cxhullst Bills •
Volalilc Sases;
Pt
I•all Ill alnlenillice;
Dust
Ll
Efficient air movement
Inaluur SlirfaCCs •
Ihist
Washdowu between groups of animals;
Feed additive's;
0
Feeder covers;
i
Feed delivery dowlispoul extenders to lculer
covers
Flusil tanks •
Agitation of recycled lagoon
C1
Flosh lank covers-,
liquid While links are tilling
O
EXICIl1I till lines to near bollonl of tanks Willi
anli-siphon vents
_
l'lusli alleys
Agitation during waswwatcr
0
Underfloor flush with underfloor ventilation
coliveyancc
I ll jechm-g-C poillls •
Agitation of recycled lagoon
n
Exlend l'CCllargC lilies Ui IlCill' bollmil oI llils
litlUld while pits are filling
Willi anti-sllilion vents
l.ik sliltiolls
Agitation during sump tank
fl
Small tank covers
filling and drawdown
OCH4ido Llrrain collcclioll • Agitation during wustewaler 1`1 Box covers
ur junction fluxes r{, by cuuveyancu
AMID(:'- November 11, 1996. Page 3

Source Cause BMPs to Minimize Odor Silc Specific Practices
End of drainpipes at • Agitation during wastewater 0 Extend discharge point of pipes underneath
lagoon conveyance lagoon liquid level
Lagoon surfaces a Volatile gas emissions; 13 Proper lagoon liquid capacity;
• Biological mixing; l Correct lagoon startup procedures;
Agitation f, Minimum surface area -to -volume ratio;
!r` Minimum agitation wlicn.pumpiug;
❑ Mechanical aeration;
n Proven biological additives
Irrigation sprinkler • I ligh pressure agitation; Irrigate on dry days with little or no hind;
nozzles 41 Wind drill 0 Minimum recommended operating pressure;
16 Pump intake near lagoon liquid surface;
Cl Pump from second -stage lagoon
Swragu t:,ok or basbi • Partial microbial decomposition; ❑ mmont or midlevel loading;
surface: • Mixing while filling;
} ❑ Tank covers;
h Agitation when emptying 0 Basin surface mats of salids;
❑ Proven biological additives or oxidants
Settling basin surface
•
Partial microbial decomposition;
Cl
Extend drainpipe oullcls underneath liquid
r,�
+
Mixing while filling;
I level;
r
Agitation when emptying
Cl
Remove sealed solids regularly
Manure, slurry or sludge
•
Agitation when spreading;
0
Soil injection of slurry/sludges;
Spreader out least
+
Volatile gas emissions
❑
Wash residual manure from spreader after use;
Y 1
M
Proven biological additives or oxidants
Uncovered mantire,
•
Volatile gas emissions while
❑
Soil injection ofskirry/sludges
slurry or sludge on field
drying
M
Soil incorporation within 48 hrs.;
sill Nees
M
Spread in thin uniform layers for rapid drying;
Cl
Proven biological additives or oxichats
t)c;ul aninl:,fs
•
Carcass decomposition
Proper disposition of carcasses
�Duad aninial disposal
1.
•
Carcass decomposition
❑
Complele covering of carcasses in burial pits;
pits 1 �
❑
Proper IOC31ion1cntlS1rllCli0ll afdispos.rl pits
h11ii11er;st1)rs
•
Incomplete combustion
M
Sccnnelary slack burners
AtvtOC - Novcmher 11, 1996, Page 4

Suurce - Cause RMI's In Minimize 041or Site Specific I'ractiecs
Slanding water around a Improper drainage; . , Grade and landscape such Iha( water drains
facilities . Microbial decomposition of away from -facilities
organic (natter
MaliurC Irackcil onto • Poorly maintained access roads baru access road maintenance
public roads hom farm
access
Additional Information : Available from :
Swine Manure Managemcnt ; 0300 ItuleIBMP Packet NCSIJ, f amity kx1clision Ccnler
Swine Production Farill Potential Odor Sources anti Remedies ; 1i13AE Pact Shect NCS(1 - BAIi
Swine Production Facility Manure Management: Pit Recharge - Lagoon Treatiucnt ; EflAri I28-88 NCSIJ - BA1i
Swine Produclioli facility Manure Manabcmeul: Underfloor Flush - Lagoon Treatnicul ; EIIAli 129-88 NCSIJ - (JAI:
I.agoou Design and Manabelncut for Livestock Manure'rrealmcat and Storage ; EBAF 103-83 NCSIJ - BAH,
Cal ibralion of Manure and Was(cwalcr Application Gquipuicnl ; EBAL. fact Shcct NCSIJ - ItAI_
Controlling Odors from Swine Buildings P111-33 NCSIJ - Swine I:i;Icnsion
Eiivironmcmui Assurance Program ; NPPC Mantia) NC Pork Producers Assoc
Options for Managing Odor ; a report from the Swine Odor Task Force NCSIJ Agri Communications
Nuisance Concems in Animal Manure Management: Odors and Flies; ITO107, 1995 Coafercnce Proceedings flnrida 000jWra6ve I'.alcnsion
A M()( November I I , 1996, Page 5

II
M, IN
00-
IF,
11 �t
Jw

DENR-FRO
Az� JAN 15 2012
NCDENR Dwo
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Charles Wakild, P.E. Dee Freeman
Govemor Director Secretary
January 24, 2012
Joel E. Robbins
Joel Robbins Finishers
297 Robbins Rd.
Council, NC 28434
Subject: Sludge Survey Testing Dates
Certificate of Coverage No. AWS090081
Joel Robbins Finishers
Animal Waste Management System
Bladen County
Dear Joel E. Robbins:
. The Division of Water Quality (Division) received your sludge survey information on
January 4, 2012. With the survey results, you requested an extension of the sludge survey
requirement for the lagoon at the Joel Robbins Finishers facility. Due to the amount of treatment
volume available, the Division agrees to an extension for the sludge survey requirement.
The next sludge survey at this facility should be performed before December 31, 2016.
Thank you for your attention to this matter. Please call me at [phone] if you have any
questions.
Sincerely,
Larry W. Wade PE
Animal Feeding Operations Unit
cc: Fayetteville Regional Office, Aquifer Protection Section
Permit File AWS090081
AQUIFER PROTECTION SECTION
1636 Mail Service Center, Raleigh, North Carolina 27699-1636
Location: 512 N. Salisbury St, Raleigh, North Carolina 27604
Phone: 91H07-64641 FAX: 919$07-6496
Internet: www.ncwaterqualitq.org
Art Equal Opportunity', Affirmative Action Employer
ne
orthCarolina
naturally

ANIMAL WASTE UTILIZATION PLAN C?O,- &
FoR 0
Producer: MURPHY SMITH RECEIVED / DENR / DWQ
AQUIFERPRnTFminN RFCTION
Location: 19829 NC 131 S.
BLADENBORO NC 28320
A�ir-FAYEMLLE
Telephone: [phone]+Type Operation: Existing Feeder to Finish SREGEOVALGF�GE
Number of Animals: 2448.00 hogs
(Design capacity)
STORAGE STRUCTURE: Anaerobic Waste Treatment Lagoon
APPLICATION METHOD: Irrigation
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops
in the fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown
and the nutrient content of the waste. Do not apply more
nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall be applied to land eroding at less than
5 tons per acre per year. Waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
10 tons per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on saturated soils, when it is raining, or
when the surface is frozen. Either of these conditions may
result in runoff to surface waters which is not allowed
under DWQ regulations.
Page: 1

ANIMAL WASTE UTILIZATION PLAN
5. Wind conditions should also be considered to avoid drift and
downwind odor problems.
6. To maximize the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more than 30
days prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. If
you choose to change methods in the future, you need to revise this
plan. Nutrient levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from your
waste management facility. In some cases you may want to have plant
analysis made, which could allow additional waste to be applied.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
This waste utilization plan, if carried out, meets the requirements
for compliance with 15A NCAC 2H .0217 adopted by the Environmental
Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
2448 hogs x 1.9 tons waste/hogs/year = 4651.2 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
2448 hogs x 2.3 lbs PAN/hogs/year = 5630.4 lbs. PAN/year
Applying the above amount of waste is a big job. You should plan
time and have appropriate equipment to apply the waste in a timely
manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
Page: 2

ANIMAL WASTE UTILIZATION PLAN
J
TABLE 1: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
-------
APPLY
RESID.
APPLIC
METH
N
TIME
12589
1
EXA
C
125.0
141.25
15
10
1412.5
I
MAR-JUN
2589
12
INA
f
2589
3
1 NA
2589
1-1
1 EXA
2589
1-1
1 EXA
2589
1-2
1 NA
2589
1-2
1 NA
2589
1-3
1 NA
2589
1-3
1 NA
END
i
120
1135
115
112
11620
C
120
I
1135
115
120
12700
MAR-JUN
W
50
144
O
I
110
11440
OCT-MAR
SB
30
120
0
I
I
110
11200
APR-JUN
W
60
144
O
I
I
112
11728
OCT-MAR
SB
120
Q
I
13�e
56
112
11440
APR-JUN
W
60
144
0
I
I
120
12880
OCT-MAR
SB
�2,6
Q
I
`lj�O
1100
120
12000
APR-JUN
T0TAL116420.5
-- - Indicates that this field is being overseeded (i.e.
interplanted) or winter annuals follow summer annuals.
NOTE: The applicator is cautioned that P and K may be over applied while
meeting the N requirements. In the future, regulations may
Page: 3

ANIMAL WASTE UTILIZATION PLAN
require farmers in some parts of North Carolina to have a
nutrient management plan that addresses all nutrients. This
plan only addresses nitrogen.
Page: 4

ANIMAL WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
See required specification 2.)
TRACT
FIELD
SOIL TYPE & CLASS--
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES.
AW N
PER AC
AC
USED
- ---
or
--------
APPLY
RESID.
APPLIC
METH
N
TIME
END
TOTAL 10
- Indicates that this field is being overseeded (i.e. interplanted) or
winter annuals follow summer annuals.
** Acreage figures may exceed total acreage in fields due to
overseeding.
* lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and 2 above:
CROP CODE
CROP
UNITS
PER UNIT
C
CORN
BUSHELS
1.25
SB
SOYBEANS
BUSHELS
4
W
WHEAT
2.4
TOTALS FROM TABLES 1 AND 2
ACRES LBS AW N USED
Page: 5

ANIMAL WASTE UTILIZATION PLAN
TABLE 1 42
TABLE 2 0 0
TOTAL
42
*** BALANCE
-2-7oo i - 5058 I
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.
Page: 6

ANIMAL WASTE UTILIZATION PLAN
*** This number must be less than or equal to 0 in order to fully
utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffeKs, filter strips along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than
the acres shown in the tables.
See attached map showing the fields to be used for the utilization of
animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient
rich and will require precautionary measures to prevent over application
of nutrients or other elements. Your production facility will produce
approximately 905.76 pounds of plant available nitrogen per year in the
sludge.
If you remove -the sludge every 5 years, you will have approximately 4528.8
pounds of PAN to utilize. Assuming you apply this PAN to hybrid
bermudagrrass hayland at the rate of 300 pounds of nitrogen per acre, you
will need 15.096 acres of land. If you apply the sludge to corn at
the rate of 125 pounds of nitrogen per acre, you will need 36.2304 acres
of land. Please be aware that these are only estimates of the PAN and
land needed. Actual requirements could vary by 25% depending on your
sludge waste analysis, soil types, realistic yields, and application
methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the
soil at the time of irrigation such that runoff or ponding occurs. This
rate is limited by initial soil moisture content, soil structure, soil
texture, water droplet size, and organic solids. The application amount
should not exceed the available water holding capacity of the soil at the
time of irrigation nor should the plant available nitrogen applied exceed
the nitrogen needs of •the crop.
If surface irrigation is the method of land application for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables 1 and 2. Failure to apply the recommended rates and
Page: 7

ANIMAL WASTE UTILIZATION PLAN
amounts of nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application
rates and amounts.
I I
I
(Application
RatelApplic. Amount
Tract
I Field I
I I
Soil Type
I Crop
I
I (in/hr)
I
I (inches)
I
2589
1 1 I
EXA
I C
I 0.35
I *0.75
2589
I I
1 2 I
NA
I
I C
I
I 0.4
I
I *0.75
2589
I I
1 3 I
NA
I
I C
I
I 0.4
I *0.75
2589
I I
I -1 I
EXA
I
I SB
I
I 0.35
I
I *0.75
I
2589 I
I
-1 I
EXA
I
I W
I
I 0.5
+ *0.75
I
2589 I
!
-2 I
NA
I
I SB
I
I 0.35
I
I *0.75
2589 I
i
-2 I
NA
I
I W
I
I 0.5
I *0.75
I
2589 I
I
-3 I
NA
I
I SB
I
I 0.4
I
I *0.75
I
2589 I
I
I
-3 I
I
NA
I
I W
I
I
I 0.5
I
I *0.75
I
Page: 8

ANIMAL WASTE UTILIZATION PLAN
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations, the application amount shown cannot
be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180.00 days of temporary storage and
the temporary storage must be removed on the average of once every
6.00 months. In no instance should the volume of the waste be stored
in your structure be within the 25 year 24 hour storm storage or one
foot of freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to
ensure that the spreader equipment is operated properly to apply the
correct rates to the acres shown in Tables 1 and 2. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may
make this plan invalid.
Call your technical specialist after you receive the waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate prior to applying the waste.
NARRATIVE OF OPERATION
L o'L Ike WYt.L 1l.;,
V0.\uGS gLVle- n %+n -�� (J�` �G lv J��� J!V k il0JL1le_ 45S(.e-M^G
4,t, 'J 6 Ge- -e- C-0 �u tJ` c Gv Tyr 41 Z-Q U"�
V 1 tJ e f h i. � rL�
Page: 9

WASTE UTILI2ATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
5. Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
B. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be considered.
Page: 10

WASTE UTILIZATION PLAN
REQUIRED_ SPECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(see Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to
wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly into water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
the site.
16. Domestic and industrial waste
showers, toilets, sinks, etc.,
animal waste management system.
from washdown facilities,
shall not be discharged into the
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 11

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
18. If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is.used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22. Waste shall be tested within 60 days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when these
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be
maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North
Carolina regulations.
Page: 12

ANIMAL WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm:S & S FARMS
owner/Manager Agreement
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
North Carolina Division of Water Quality (NCDWQ) before the new
animals are stocked. I (we) also understand that there must be no
discharge of animal waste from this system to surface waters of the
state from a storm event less severe than the 25-year, 24-hour
storm. The approved plan will be filed on -site at the farm office
and at the office of the local Soil and Water Conservation District
and will be available for review by NCDWQ upon request.
Name of Facility Owner: MURPHY SMITH
(Please print)
signature: Inmod4 JL& Date: f 0 - 7 -- 9 _
.Z01 go,
,._
Name of Manager(If different from owner):
Signature:
Date:
Name of Person Preparing Plan: (Please print)Samuel G. Warren
Affiliation:USDA-- NRCS Phone No. 910-862-6936
Address (Agency): 122 Ag. Service Ctr.
Elizabethtown NC 28337
Signature: 1 v' ��� Date: 16 /l I',
Page: 13

IN'lortality Management Methods
(check; which method(s) are being implemented)
❑ Burial three feet beneath the surface of the ground within 24 hours after
knowledge of the death. The burial must be at least 300 feet from anv flowing
stream or public body of water. , I
Rendering at a rendering plant licensed under G.S. 106-165.7
Complete incineration
0 In the case of dead poultry only, piacing in a disposal pit of a size and design
approved by the Department of A-riculture
Anv method which in the professional opinion of the State Veterinarian would
make possible the salvage of part of a dead animal's value without endangering
human or animal health. (Written approval of the State Veterinarian must be
attached)
Insect Control Checklist for Animal Operations
Source Cause 1IMPs In Cunlrol laseels Site Specific Practices
Liquid Syslews
Musk1 cjlawrs 41 Accunaulaliou of solids flush sysleln is designed and operaled
sufticienlly to rcalovc accumulated solids (roil
gllncrs as designed,
3 tteniove bridging ofaccnrnulatcd solids;a
lliscttarge
1.111;0ulls ;utd fits Crusted Solids 7- Mainlain lagoons, seulinl; bilSiSIS alid hits where
licsl breeding is apparent to 111iuimizl: 111e
crusting of solids to a depth of no more than 6 -
8 inches over morn: than 30% of surface.
Excessive Vegelalnve Decaying vegetation Maintain vegetalive control along banks of
t ir�llvlh lapons and other impoundments to prevcnl
acC11r111dali011 of deCayn11& vegetative mallcr
along water's edge on iuipoundnicnt's perinicler,

Swine Farm Waste Management Odor Control Checklist
Suur'ce Cause 11MI's to Miniasice ndoi. Silc Specific Practices
hWntstead • Swine production 0� Vegetative or wooded buffers;
Recommended best management practices;
Good judgment anti common sense
Animal body surfaces 6 Dirty manure -covered animals G1 Dry floors
Flom. surfaces • Wet ntauure-covered floors Slotted floors; {fie
' Waterers located over slotted floors;
tC feeders at high end of solid floors;
Scrape manure buildup from floors;
n Underfloor ventilalion for drying
hLuanre collection pus a Urine; 0 frequent manure removal by flush, hit recharge,
• Partial uticrobial decomposition or scrape;
C1 Underfloor ventilation
Ventilation exhaust huts • Volatile Eases; ja Ian tttainteflance;
Dust n Efficient air movement
hlaluur surfaces • I]ust Washdown between groups of aninials;
Feed additives;
0 Feeder covers;
< K heed delivery downspout extcndurs to feeder
covers
Flush IZutks a Agitation nfrecycled lagoon C1 Flnslt tank covers;
liquid while tanks are tilling CI Emend fill lines to near bottom of tanks with
anti -siphon vents
blush alleys • Agitation during wastewater CI Underfloor flush with undariloor vctttilalion
conveyance
flit iccltarl;c points 0 Agitation of recycled lagoon n Exlead recharge lines to near l}otturtt aal'Nils
liquid while pits are filling wilh anti -siphon vents
I.il't slakow, Agitation during sump tank f-7 Sump trunk covers
lY filling and drawdown
Oulsitle drain collection Agitation during; wastewater n Ilox covers
or junction boxes conveyance
' , ANIOC' - Ni3vcutbcr 11. 1996, l'al;e 3

Source Cuuse BMPs to Minimize Odor Site Specific Practices
End of drainpipas at • Agitation during wastewater, ❑ Extend discharge point of pipes undenieath
lagoon conveyance lagoon liquid level
Lagoon surfaces • Volatile gas emissions; 43 Proper lagoon liquid capacity;
• Biological mixing; E Correct lagoon startup procedures;
• Abitauan Ef� Minimum surface area -to -volume ratio;
Minimum agitation when,pumping;
❑ Mechanical aeration;
❑ Proven biological additives
irrigation sprinkler
nc "Ies
• 11igb pressure agitation; Irrigate on dry days wilh fildc or no wind;
• Wind drift Cl Minimum recommended operating pressure;
'A Pump inlake near lagoon liquid surface;
❑ Pump from second -stage lagoon
Swroge lust; or bt►sin
•
Partial microbiul deco►►ipusilion;
C'i
Holloua or midlevel loading;
surtace
•
Mixing while filling;
❑
'Tank covers;
•
Agitation when emptying
❑
Basin surface mats of solids;
❑
Proven biological additives or oxidants
SLA11irag NkSin surl'aca
•
Parlial mizrobiul decomposition;
❑
Exle:nd drainpipe ontlCls undernealh litlltid
Mixing while filling;
level;
1
1� 1
Agitation when emptying
0
Remove selticd solids regularly
N9a11111•c, Slurry or sludge
•
Agitation when spreading;
❑
Soil injection of slurry/sludges;
sprcuder outlets ilk
Volatile gas emissions
Q
Wash'residual manure from spreader after use;
❑
Proven biological ldditives or nxidunlS
thicoverod ur.►nura,
•
Volatile: gas emissions while
. ❑
Soil injection al'slurry/sludges
slurry or sludge on field
drying
CI
Soil incorporation within 48 tars.;
surlaccs
M
Spread in thin uniform layers for rapid drying;
0
Proven biological additives or nxidunlS
Dead allinulls
a
Carcass decomposition
Proper disposition of carcasses
�hcael aaln►ill diglosai
•
Cal -cuss decomposition
0
Complete covering of Carcasses in bttrlal pals;
plls
p ? ❑ Proper location/conslruclion ol'disposul Ails
lilCi1W1'i11["S � IV, • Incarliplele comblisliolt f-] Secondary slack burners
AhIOt: - November 1 t , 1996, Page 4

Source Cause 11MPs to Minimize Odor Site Specific Practices
Standing water around • Improper drainage; Grade and landscape such that water drains
facilities a Microbial decomposition of away.front-facilities
organic matter
Alanure tracked onto • Poorly maintained access roads Faun access road maintenance
public roads from farm
access
Additional Information :
Swiuc Minmro Management ; ONO ItuleffiMP Packet
Swine Production Farm Potential Odor Sources and Remedies ; FBA1? Fact Sheet
Swine Production Facility Manure Management: Pit Recharge - Lagoon Treatment ; EBAE 128-88
Swine Production Facility Manure Management: Underfloor Flush - Lagoon'frealmew ; CRAM 129-88
Lagoon Design and Muuagrment 11or Livestock Manure Treatment and Storage ; EIIAH 103-83
Calibration of Manure and Wastewater Application L'•quiptnt:nt ; EBAE Fact Sheet
Contrulling Odors from Swine Buildings; Pill-33
luovironmental Assurunce Program ; NPPC Manual
npi ions for Manugiug Odor ; a report from the Swine Odor Task Force
Nuisance Cnucunis in Animal Manure Management: Odors anti Flies ; 11110107, 1995 Conference Proceedings
AW)f,' - N0VL:,Idh(;r i I, 1990, h1j;C 5
Available From :
NCSI1, Cmimy Exicasion Ccnwr
NCSI1 - IIAI:
NCSU - IIAH
NCStJ - BAIi
NCSIJ - IIAI:
NCSI1 - BAI:
NCSU - Swine Extension
NC fork 11roducefs Assoc
NCSI1 Agri Communications
FloridaCooperative Extension

wool,.:_
i %tom-�-.' r • «'� r1� lr .-•+Ip r sty w' y --a• i ,��•� � � ..
r''r-'
4t t -.aY 'T.` t~-•: fit" "u { "[ ''` �^ Ta�''ifr} S �'` _ }. �►_- `ea a"�'
le.
+t'
�" i y :. �• t;.:��'�:S'''t tef-v-"'a. �.L'F' _.s°�'F •'r. �.::^? r r=•�ryr�.�ti -..: y Z`a�' y �•��"-s
r"�;+s` wf'S,pr �..: ;*.:. r Z Fa +.: C �, r �,yr�- �•�.• :t'.�G�r '� �: -•j - '•' �eX S. � i "� '�.:r S j, •�...r+r..
.'.J- K-k �'+°„ '- •/.r"r rSi= [}-1 -$��" 4i'�. 1:•Yit t5 ,1i4 •r• 'ha :�• _� 0� _!.- �^�
,i%7 t?�� �at?'•'.�rf , f.r :iti.d y r V}3• ry c a
c.'• �. :Y r••c!w r'+K'I•f�-,r^i`'� �t ,'' L� 'l, i•.. r '• :-}� }: ,r r - �� `,`:
�♦t SSA.. y, _ - r •1 -+e Y;�, :�tM-�." � � �t al i � �� ir. � � � r :,., -a }. y IsI +�'Y�
��'R..>.r �'� 'z' �.� Y i-�: i • ..+tom r�'��!�' Y - x - � �` - F ��4s +Ct�. :� "'+: " ' �.s,���.%•.
'� _ �}ti, r �.i J° `� s Y : : ;+C-� '_ Lam.%�' _ ✓s� � `r � R �_ H•�r .,. ` •.R� �.�;� � ;��Lr
�d�� v� �, � •�.r= Y rff'ti.� -5 s ra,:�.h� ,:r _• 'y } � s^�r".. Lr� SL t1 'rrt_� �_�S
yy�s..y �" -tti -1• S� .a 4 w "C i.� „�1!�"4 � ` ''� - i � _�. yyy h_ v � � `� .+� t, f• ��v -.
�� �.\ .t.• a; + l T �' i r' •1
-:r,. '�;�.'.+�' � _ .,a� =' -'r-✓ .:- _ `; T•_._`J �:�.li.��i�:'• ` Lam:..._.' �'' �.•"� � ��'9�w- �- �+� - t -+�•. +r �?-•_� y;,_4
1�• ji,•i wt,,,._ _hr - 4:- •:-�;•:.� fr4:.7: T :'�... x<: - +l..� - ,� __ �."'. ._,, _ r -, _ .Yp�Ys2`.i,; . i . �+f `X •�
;' �1°^ -. ' c"v � � ,+i -'�'i:'• s"�'. � "' _ .'4__. � �..r.�e-rises; �+r �, Y�.•� ,� '' a�.�r ;�:
.s^ titL_:: -Z" r -. <'.� ; •.Z3 `;��_ �. r �,. �•, ..- I � cj.�_ �a-' 'v •• � � +,[ rr1;r: t-,fis'.• 3 _ � a
'_iR• ,�S L �'S" a * .ti i l'�••� 'r{ t r '� i' _ , t : }� : ,r4i y.�, }... rw! r ii �'? `= �
ta; .; .•r 1..'► %� T } yr_ .' 1 �+ Cat ` ir, i� t
.1 -.. ''_•pry.. `� r r4rf � k r• i - - •. f:'` -��:: __ cry: Kt ; 4 �� .t•� - +'- cT' �
-+`ww �s �' :> -. '-�� _ `�r"�•. 'V _ ,i-�k tr^• _11w
�yrs�:7�A.: ���t 1....� t_ w^':+V[x;'. ':t•>� ': ? r � „'Ka. �'. � „•ICY ..! ca �.. - _✓. Y • _ - ;'y :�* "9 �'�� .�� �f •~~ .';s��yj` ~ T'
`^�'�.'• '.1 ;7 ''i:.l C•: '- ' �••'er _ . 1: •: -•e .' •: '= - ',iY�'• �i: .�".;h - a' - - : a: .yrr - �•.' .Gty,r
� ..�� .v� _ c: . '• - _ .C�+.fir � •-i•' - •z � + � Y _.1� '_ti v.• _ i ':ti � :`:-r - �'hs�ri: s; ,.
` 4 "`s.*~- r�? f.r :a K/ .t' �•;*tea ~ Y {'; Tom+:.l i
+•,` - _ .t ,Yiy .�i �.«-:;�•,+.�., :. Y.``�. ''. ty ��S 1�ir, r �}'?I. .)r: .IJ: 'c Sr,.� ,'ila _ �.rr;• .��'� -
� �� 'x �xr yc'_ 'J�''' Y -=:' iS r,.i -''• E+t`i ii.� ��rS �; � 1 ., � i •sF .,,Z-: �ri � �r w:'1. -
J r
•`�,;-�'_ v.• s• v .• ; - r: Z x .r \?
�w . ,c- ��� f�J'.�5 - ,tt.6 l„i- •ray ��•-�-• 1. `"t � �� � K t �` tY + 'r� •`
r; tit
L�1"' � ! : V+ < i � s alr'f?!l��,..,�� r;` ! 4�� �-•;.y.� .�: -. + r ..r r• : i•!,j • N!'�Jri, r
a .sue{�� +5 _F.�=�: ��, 4.� `.r ��',{`.•`ylb+�•�' +�-y ..r
f

NCDER
North Carolina Department of Environment and Natural Resources
Beverly Eaves Perdue
Governor
Murphy Smith
Double S Farm
19829 Hwy 131 South
Bladenboro, NC 28320
Division of Water Quality
Coieen H. Sullins
Director
May 20, 2009
RECEIVED
WYU=
DENR - FAYETf Ell1LLE REGIONAL OWE
Subject: Application for Renewal of Coverage for Expiring Animal Waste State Non -Discharge General Permit
Dear Permittee:
Dee Freeman
Secretary
Your facility is currently approved for operation under one of the Animal Waste Operation State Non -Discharge General
Permits, which expire on September 30, 2009. Copies of the new animal waste operation State Non -Discharge General
Permits are available at htta://h2o.=.state.nc.uslaps/afou/aipplications:htm or by writing or calling:
NCDENR— DWQ Animal Feeding Operations Unit
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
In order to assure your continued coverage under the State Non -Discharge General Permits, you must submit an application
for permit coverage to the Division. Enclosed you will find a `Request for Certificate of Coverage Facility Currently
Covered by an Expiring State Non -Discharge General Permit.' The application form must be completed and returned by
April 3, 2009. Please note. you must include two (2) copies of your most recent Waste Utilization Plan with the
application form.
Failure to request renewal of your coverage under a general permit within the time period specified may result in a civil
penalty. Operation of your facility without coverage under a valid general permit would constitute a violation of NCGS 143-
215.1 and could result in assessments of civil penalties of up to $25,000 per day.
If you have any questions about the State Non -Discharge General Permits, the enclosed application, or any related matter
please feel free to contact the Animal Feeding Operations Unit staff at 919-733-3221.
Sincerely,
Ted L. Bush, Jr., Chief
Aquifer Protection Section
Enclosures
cc (w/o enclosures): Bladen County Soil and Water Conservation District
Fayetteville Regional Office, Aquifer Protection Section
AFO Unit Central Files — 09-82
Murphy -Brown, LLC
AQUIFER PROTECTION SECTION
1536 Mail Service Center, Raieiah, Ncnh Carolina 27699-1636 One 1
Location: 2728 Capital Boulevard, Ra#eigh, North Carolina 276�4 Nof fhCarolina
Phone: [phone] kF-I 1: 91t-715-0588: FAX 2: 919-715-604E Customer Service: 1-87 323-6748 ] r j [� �y��, f
Intemet www.ncwale uali .oro �% v fL (✓j
AP Equal OpPGT-wrlty ', Affifir laiive A kTi Fmployer