090064_CORRESPONDENCE_20171231

North Carolina Department of Environmental Quality
Pat McCrory
Govemor
Shannonbrooke Farms, LLC
Yorick Nursery
PO Box 2212
Elizabethtown, NC 28337
Dear Shannonbrooke Farms, LLC:
Donald R. van der Vaart
F ��� ED Secretary
October 30, 2015 NOY O 9 2015
-x:- w V2,
FAYETTEVILLE REGIONAL OFFICE
Subject: Certificate of Coverage No. AWS090064
Yorick Nursery .
Swine Waste Collection, Treatment,
Storage and Application System
Bladen County
In accordance with your Notification of Change of Ownership received October 21, 2015, we are hereby
forwarding to you this Certificate of Coverage (COC) issued to Shannonbrooke Farms, LLC, authorizing
the operation of the subject animal waste management system in accordance with General Permit
AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
and land application of animal waste as specified in the facility's Certified Animal Waste Management Plan
(CAWMP) for Yorick Nursery, located in Bladen County, with a swine animal capacity of no greater than
the following annual averages:
Wean to Finish: Feeder to Finish: Boar/Stud:
Wean to Feeder: 2600 Farrow to Wean: Gilts:
Farrow to Finish: Farrow to Feeder: Other:
If this is a Farrow to Wean or Farrow to Feeder operation, there may be one boar for each 15 sows. Where
boars are unnecessary, they may be replaced by an equivalent number of sows. Any of the sows may be
replaced by gilts at a rate of 4 gilts for every 3 sows.
This COC shall be effective from the date of issuance until September 30, 2019, and shall hereby void
Certificate of Coverage Number AWS090064 dated October 1, 2014. Pursuant to this COC, you are
authorized and required to operate the system in conformity with the conditions and limitations as specified
in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting and
maintaining the required monitoring data and operational information must be established for this facility.
Any increase in waste production greater than the certified design capacity or increase in number of animals
authorized by this COC (as provided above) will require a modification to the CAWMP and this COC and
must be completed prior to actual increase in either wastewater flow or number of animals.
Please read this COC and the enclosed State General Permit carefully. Please pay careful attention to the
record keeping and monitoring conditions in this permit. Record keeping forms are unchanged with this
General Permit. Please continue to use the same record keeping forms.
If your Waste Utilization Plan (WUP) has been developed based on site -specific information, careful
evaluation of future samples is necessary. Should your records show that the current WUP is inaccurate
you will need to have a new WUP developed.
1636 Mail Service Center, Raleigh, North Carolina 27699-1636
Phone: [phone]Internet: http:llwww,ncwater.org
An Eouai ODDortunity 1 Affirmative Action Emo3over - Made in Dart by recycled oaoer

The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Per NRCS standards a 100-foot separation shall be maintained between water supply wells and any lagoon,
storage pond, or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the Animal Feeding Operations Program for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
In accordance with Condition II.22 of the General Permit, waste application shall cease within four (4)
hours of the time that the National Weather Service issues a Hurricane Warning, Tropical Storm Warning,
or a Flood Watch associated with a tropical system for the county in which the facility is located. You may
find detailed watch/warning information for your county by calling the Wilmington, NC National Weather
Service office at [phone], or by visiting their website at: http://www.weather.gov/ihn/
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office staff
may be reached at 910-433-3300. If you need additional information concerning this COC or the General
Permit, please contact the Animal Feeding Operations Program staff at [phone].
Sincerely,
a�
----for -S.-Jay.Zimmerman,. P.G. _
Director, Division of Water Resources
Enclosure (General Permit AWG100000)
cc: (Certificate of Coverage only for all ccs)
Fayetteville Regional Office, Water Quality Regional Operations Section
Bladen County Health Department
Bladen County Soil and Water Conservation District
WQROS Central Files (Permit No. AWS090064)
Murphy -Brown LLC

NCDENR
North Carolina Department of Environment and
Pat McCrory
Governor
Natural Resources
John E. Skvada, III
RECEIVED
July 2, 2014 JUL _ 8 2014.
All In Farms Inc
All In Farms, Inc. (Yorick Nursery) DENR-FAYETTEVILLE REGIONAL OFFICE
PO Box 535
Elizabethtown, NC 283370535
Subject: Additional Information Request
Application No. AWS090064
All In Farms, Inc. (Yorick Nursery)
Bladen County
Dear All In Farms Inc:
The Animal Feeding Operation Branch of the Division of Water Resources (Division) has completed a
��. preliminary review of your renewal permit application package. Additional information is required
1. before we may continue our review. Please address and submit the following item(s) within 30 (thirty)
days of receipt of this letter:
Missing Waste Utilization Plan and Field Maps:
Our records show that a copy of your waste utilization plan (WUP) or nutrient
management plan (NMP) along with the field maps is missing with your permit application
package.
Please reference the subject application number when providing the requested information. All revised
and/or additional documentation shall be signed, dated and sent to my attention at the address below.
Information can also be submitted electronically at [e-mail].
Please feel free to contact me at [phone] if you have any questions regarding this letter,
Sincerely,
J. R. Josh]
Animal Feeding Operations Branch
cc: Fayetteville Regional Office, Water Quality Regional Operations Section
WQROS Unit Central Files - AWS090064
Murphy -Brown LLC
1636 Mail Service Center, Raleigh, North Carolina 27699-1036
Phonc: 919-807-64641 Internet: hitpalwww.ncdenr.go%
An Fqual Opportunity 1 Aliirmalive Action Employer— Made in part by recycled paper ..
Secretary

Aa
NCDEHR
North Carolina Department of Environment and Natural Resources
Division of Water Quality
Beverly Eaves Perdue Coleen H. Sullins
Governor Director
All in Farms, Inc
Yorick Nursery
PO Box 535
Elizabethtowng, NC 28337
Dear All in Farms, Inc:
December 3, 2010 RECEIVED
DEC 0 9 2010
Dee Freeman
Secretary
OENR-FAYEITEMLE REGIONAL OFFICE
Subject: Sludge Survey Testing Dates
Certificate of Coverage No. AWS090064
Yorick Nursery
Animal Waste Management System
Bladen County
The -Division of -Water Quality (Division) received your sludge survey information on November .
22, 2010. With -the survey results, you requested an extension,of the sludge survey requirement.
-for the lagoon at the Yorick Nursery facility. Due to the amount of treatment volume available,
,the Division agrees that a sludge survey is not needed until 2014•for your lagoon.
:The next sludge survey for the lagoon at Yorick Nursery facility should be performed before
December 31, 2014. Thank you for your attention to this matter. Please call me at (919) 715-
6937 if you have any questions.
Sincerely,
_*Z161Y
Miressa D. Garoma
Animal Feeding Operations Unit
cc: Fayetteville Regional Office, Aquifer Protection Section
Permit File AWS090064
'E313 tvia+; str-ks Center. Raleigh, North Camlina 21699-1636
Lt;:;a ;ion 27'1kl�,3; r«s 9d . Raieigh. Norh Carolina 2:����
i ors 919- 33-3221 `: c=.X: 919.715 0568 7 Cuo;n slu Sera,e1-,s, 7-623-6248
One.
NorthCarolina
; aturally

l
Murphy -Brown, LLC
Grower(s):
Farm Name:
6/23/2009
2822 Hwy 24 West
P.O_ Box 856
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN C)C(- (xLt
Yorrick All -in
County: Bladen
Farm Capacity:
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder 2600
Feeder to Finish
Storage Structure:
Storage Period:
Application Method:
RECEI EV p
JUL t 7 aw
Dal R-FA"INILLEAE610NAf GFRCE
Anaerobic Lagoon
>180 days
Irrigation
RECEiVEDD
AQUIFFJ 'Ppo'rFrT1rlAf
gF,fll�N
QUL 01 Z009
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy_ Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft', tons, etc.):
Capacily Type Waste Produced per Animal Total
Farrow to Wean
3212 gal/yr
gal/yr
Farrow to Feeder
4015 gal/yr
gal/yr
Farrow to Finish
10585 gal/yr
gal/yr
2600
Wean to Feeder
223 gal/yr
579,800 gal/yr
0
Feeder to Finish
986 gal/yr
- gallyr
Total 579,800 gal/yr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs):
Capacity Type Nitrogen Produced per Animal Total
Farrow to Wean
5.4 Ibs/yr
Ibs/yr
Farrow to Feeder
6.5 Ibs/yr
Ibs/yr
Farrow to Finish
26 Ibs/yr
Ibs/yr
2600
Wean to Feeder
0.48 Ibs/yr
1,248 Ibs/yr
0
Feeder to Finish
2.3 Ibs/yr
- ibs/yr
Total 1,248 Ibstyr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner_
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 4.489
Total N Required 1st Year: 1274,382
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops: 1,274.38
Total Nitrogen Produced by Farm: 1,248.00
Nitrogen Balance for Crops: (26.38)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2of8

Reception
Tract Field Irrigated Sall Ist Crop Time to IstCrop latCrop LbsNIAc Lbs N TotalThs N
Acreage Typo /Ac Utilized
wr-naKr.r.�dr.-Mrs
_Code
_
r;©�0
®
3(a) of 8

Specifications
I Reception Area
Tract Field Irrigated Soll lot Crop Time to lst Crop-lattrop Lbs N/Ac Lbs N Total lbs W-2nd Crop Time to 2nd Crop 2nd Crop Lbs NlAc Lbs N Total The N:
_
3(b) of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized / unit yield
A
Barley
1.6 lbs N / bushel
B
Hybrid Bermudagrass - Grazed
50 lbs N 1 ton
C
Hybrid Bermudagrass - Hay
50 lbs N / ton
D
Corn - Grain
1.25 Ibs N 1 bushel
E
Corn - Silage
12 lbs N 1 ton
F
Cotton
0.12 lbs N / lbs lint
G
Fescue - Grazed
50 lbs N 1 ton
H
Fescue- Hay
50 lbs N 1 ton
I
Oats
1.3 lbs N 1 bushel
J
Rye
2.4 lbs N I bushel
K
Small Grain - Grazed
50 lbs N I acre
L
Small Grain - Hay
50 lbs N 1 acre
M
Grain Sorghum
2.5 lbs N 1 cwt
N
Wheat
2.4 lbs N 1 bushel
O
Soybean
4.0 lbs N 1 bushel
P
Pine Trees
40 lbs N 1 acre 1 yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables_
See attached map showing the fields to be used for the utilization of animal waste.
4of8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications
PANT/animal Farm Total/yr
Farrow to Wean
0.84
Farrow to Feeder
1
Farrow to Finish
4.1
2600 Wean to Feeder
0.072 187.2
0 Feeder to Finish
0.36 0
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 187.2 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 936 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 3 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 7.488 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
`This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5 of 8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract_
_ Hydrant
ape
Crop
in/hr
*_inches
10317
1
LeA
C
0.65
1
10317
2
Ce
C
0.75
1
10317
3
KeA
C
0.6
1
10317
4
KeA
C
0.6
1
6of8

Additional Comments:
All land should be cut for h
Zone 1 is planned for the high nitrogen utilization rate for overseeded small
grain crops. This requires that all irrigation events attributed to bermuda
cease by Sept. 15. In addition, no applications shall be made to small
grain in December or January. The 100# rate must be split equally between
the Fall and Spring windows for overseed.
7of8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm: Yorrick All -In Nursery
Owner:
Manager:
Owner/Manager Agreement:
Uwe understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. 1 also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
r �
Name of Facility Owner:
Signature:
Name of Manager (if different from owner):
Signature:
Name of Technical Specialist: Kraig Westerbeek
Affiliation: Murphy -Brown, LLC.
Address: 2822 Hwy 24 West, PO Drawer 856
Signature:
Date
8 of 8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recieving crop type, or available land.
Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic condifions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
6 When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order to control odor and flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those owned
by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2of3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3of3

Sheetl
IRRIGATION SYSTEM DESIGN PARAMETERS
Landowner/Operator Name: Ali -In Yorrick Nursery
Address:
Elizabethtown, NC
Telephone: [phone]
Table 1 - Field Specifications
Approximate
Maximum
Useable Size
Zone of Field
Number facresl
Soil Tune Slone %
Maximum
Application
Rate
Cronf sl f infhrl
County: Bladen
Date: 6/23/2009
Maximum
Application
per Irrigation
Cycle
hnrhac�l rnmmantc
Bermuda, small qrain­���
Bermuda, smaCgmm����
©
�®
Bermuda, •
1
Bermuda, small grain
-

Sheet3
TABLE 3 - Solid Set Irrigation Gun Settings
flake, Model and Type of Equipment Senniger 7025 Full throw & Nelson P65 Half throw sprinklers
Operating Parameters
Wetted Hydrant Spacing(ft) Application Nozzle Operating Operating
Number of Diameter Along Between Rate Diameter Pressure Time
Zone No Sprinklers (feet) Pipelines Pipelines finlhr) (inches) at Gun(osi) at Hvdrant(hr.)

Sheet3
t,ommenis-Acres per zone
1.299
1.038
1.114
1.038
4.49

Sheet4
TABLE 4 - Irrigation System Specifications
Traveling
Solid Set
Irrigation Gun
Irrigation
Flow Rate of Sprinkler ( pm) )
20
Operating Pressure at Pump psi
64.3
Design Precipitation Rate in/hr
0.30
Hose Length feet
xxxx XXX
Type of Speed Compensation
XXXXXXxx
Pump Type PTO, Engine, Electric
Electric
Pump Power Requirement (h)
8.7
TABLE 5 - Thrust Block Specifications
THRUST BLOCK
LOCATION
AREA sq. ft.)
90 degree bend
2.12
Dead End
1.50
Tee
1.05
Gate Valve
1.50
45 degree bend
1.14
Page 1

Sheets
IRRIGATION SYSTEM DESIGNER
Name: Kraig Westerbeek
Company: Murphy -Brown, LLC
Address: PO Box 853 Warsaw, NC
Phone: [phone]
Required Documentation
The following details of design and materials must accompany all irrigation designs:
1. A scale drawing of the proposed irrigation system which includes hydrant locations, pipelines, thrust block locations and buffer areas where applicable.
2. Assumptions and computations for determining total dynamic head and horsepower requirements.
3. Computations used to determine all mainline and lateral pipe sizes.
4. Sources and/or calculations used for determining application rates.
5. Computations used to determine the size of thrust blocks and illustrations of all thrust block configurations required in the system
G. Manufacturer's specifications for the irrigation pump, traveler and sprinklers).
7. Manufacturer's specifications for the irrigation pipe and/or USDA-NRCS standard for IRRIGATION WATER CONVEYANCE.
8. The information required by this form are the minimum requirements. It is the responsibility of the designer to consider all relevant factors at a particular site and
address them as appropriate.
9. Irrigation pipes should not be installed in lagoon or storage pond embankments without the approval of the designer.
NOTE: A buffer strip of 50' or wider must be maintained between the limits of the irrigation system and all
perennial streams and surface waters per NC Statutes.

Sheet6
Narrative of Irrigation System Operation
This system is designed to replace an existing solid set irrigation system for this farm. All sprinklers are
permanent' in their design, with the zones valved off separately from one another. For this reason, the
sprinklers specified are designed to allow equal run time for both full and half throw sprinklers.
Zones can be changed during operation by opening the next desired zone's valve, and then closing the current
zone's valve. Using this method, zones may be changed without cutting the pump off at the lagoon.
Run times specified in this design are for planning purposes only. Actual soil conditions will dictate run
times and total applications.
A gate valve should be installed immediately downstream of the electric pump used to provide backpressure
to the system during start up.
Thrust block sizings are provided, although thrust blocks are not required to be installed due to the low
system pressure.
SB515 setbacks apply to all areas of this design and include the following:
50' from property not owned by the producer
75' from blue line streams
200' from residences not owned by the producer
1 00'from water wells

Sheet?
CALCULATIONS
_
Sprinkler Specifications
Sprinkler Type:jSenniger 7025 !Nelson P65
Size: , 5� /16 -
! inches 7/32
Inches
!
_ _Nozzle
_ Sprinkler Pressure: j 50I
Flowrate(GPM):j 20
psi 50
gpm �� 9.8
psi
gpm
Wetted Diameter.i 127jfeet
! 108
feet
!
_Sprinkler Spacings
? I !
Desired Spacing (%):, 60
% 1 ii
I
Design Spacing(feet):; 76.21*PVC
irrigation pipe normally comes in 20' pieces,
I
so round to the nearest multiple of 20. I
I
Actual Spacing (feet): E 801feet
I 80 feet I
Actual Spacing (%):; 63
% 1 74J%
Apl2lication Rate I
! I I
Application Rate = (96.3xFlowrate)tsprinkler spacing squared
I I I I !
I
Design App. Rate =1 0.30!inlhr 0.151inlhr
Run Time per Set
- - - T
Run Time per set = Desired application ! Design application rate = hours ! j
C I
I 1
Desired app. (in.) = h 0.51inches
I I ! 1
_Run time per set =I 1.661hrs.
I*same for half throw; half of the application rate
_
_ I
I I
half of the land area covered
Mainline Velocity j
1
Velocity - .408 x Flowrate 1 pipe diameter
squared feettsec.** 1
!
"For buried pipelines, velocity should be below 5 feet per second 1
_ Pipe size: 4jinches
# Sprinklers Oper.: I 8.5
! I
I
Velocity=' 4.341fUsec. I I I
I !
Maximum Lateral Line Entrance Velocity
!Pipe size: I 2 inches
# Sprinklers Oper.:l 31 1*All zones may show >5fUsec. Velocity at the',
�- Velocity =j 6.121ft/sec. (entrance of 2" lines. Very shortli_ved max. I
I ! 1as design allows for branching, ect.
Page 1

Sheet7
Maximum Mainline Friction Loss
_ Lateral Used:jZone I 1
Total distance:+ 1080 feet
I
Friction Loss is figured using HazenMilliam's Equation
1
Friction Loss= 1.54
feet/100 feet j
Max. Mainline Loss = I 16.6
feet or 1 _ 7.2 psi
j
i
*does not include loss for 6" section, see below
1
Maximum Lateral Line Loss
_
Lateral line friction loss is determined using the assumption that 314 of the Friction Loss
occurs in the first 113 of the lateral line
Total Lateral Length:
2201feet
# sprinklers on Lat.:
31
Frict. Loss at 113 ]at.
1 4.801feet i i
I
Max. Lateral Loss:
6.401feet or 1 2.771psi
I I !
--
i
Total Dynamic Head 1
1 1
Sprinkler Pressure: l 501psi i
I
Lateral Line Loss: 1 2.77,psi
I
1
Elevation head: l 01psi I I 1
I
Mainline loss: ` 5.31 psi I'includes 4"&6" sections 1
i Suction head and lift: - 3._2 psi I -
- -
5%fitting loss: 3.11psi 1
TOTAL(TDH) _; 64.31psi or 1 148.61feet
I
1
Horsepower Required I I I
= Flowrate x TDH(feet)139601 Pump effeciency 1
1
!
_Horsepower
Pump Description: I Berkeley B1.5 TPM
Pump Efficiency:; 73.21% 1 I 1
Horsepower Req'd:I ^ 8.71Hp
Page 2

Sheet?
Thrust Blocking_
Thrust Block Area = Thrust / Soil Bearing Strength
1
�_ Thrust:
1800
feet I
1
SoiE Bearingren Stgth:
1200
feet
I
— - End Cap:
l 1.5
ft2
_ 90 degree elbow: , 2.1
ft2
i Tee: l 1.11ft2
45 degree elbow:; 1.1 Ift2
Pipe Pressure Rating Check
Pressure Rating of Pipe to be Used:
160Ipsi
I
I
_
Max. Pressure on system when running:}
64.31psi
I
— ! 70% of Pressure Rating:,
112{psi
1
If Max. Pressure on system is less than 70% of Pressure
Rating, OK
' i
Net Positive Suction Head Check 1 1 1
NPSHA: 21.52 M 1=(12.7*2.31)-7.4-(0.18*2.31)
}"suction head f lift is 7.4' 1
s
NPSHR:� 17.8I*from pump curve I 1 1
Ilf NPSHA>NPSHR, OK I I I I
Page 3

Sheet8
Acreage Calculations
1
1
21
3
4
Total
Zone #
Ext.
e
Ac. Per
180 deg.
ac.per
Acres
11
4
0.161
22
0.147
0
0
5
0.073
1.299
21
11
0.161
2
0.147
0
0
8
0.073
1.038
31
1
0.161
5
0.147
0
0
3
0.073
1.114
4
1
0.161
2
0.147
0
0
8
0.073
1.038
4.489
I
Notes for charts used:
I
1
Table 4, column E, weighted for 127' diameter
I
2
80' x 80' interior diameter converted to acres
3
Table 6, Column G, weighted for 108' diameter
I
4
Interior area divided by 2
Page 1

Ail in Yorick Nursery
Spray Fields
Scale: 1 "=200'
Total Field 1 3.06 Ac. I w/100'
iset
Total Field 3 = 3.11 Ac.
e� �2All
+ f
Total Field 2 = 2.74 Ac. .� - a `[lass I60VOC
X
CC CL
�^
- 4 LA
6/2009

All In Yorick
Spray Fields
Scale: 1 =200
Nursery
Total Field 1 = 3.06 Ac.
Total Field 2 = 2.74 Ac.
Well w/100,
offset
6/2009

All In Yorick Nursery
Spray Fields
Scale: 1 "=200'
Total Field 1 = 3.06 Ac.
s
Total Field 2 = 2.74 Ac.
f 1 Ww/100P)O '
set
6/2009

0� W A 7-F9 pG RECEIVED Michael F. Easley. Governor
William G. Ross Jr., Secretary
r AMA M Now Carolina Department of Environment and Natural Resources
Coleen H. Sullins Director
OENR — FAYETULLE REGIONAL OFRCE Division of water Quality
August 11, 2008
All In Farms Inc
All In Farms, Inc. (Yorick Nursery)
PO Box 535
Elizabethtown, NC 28337
Subject: Sludge Compliance Requirement Change
Dear Pennittee:
In accordance with Condition III.19 of State General Permit AWG100000, your facility is
required to maintain compliance regarding sludge accumulation in your animal waste treatment
lagoon(s). As you know, the previous compliance limit was to have a minimum of four (4) feet
of treatment depth between the designed stop pump and the average elevation of the top of the
sludge blanket. This requirement was based on NRCS Standard No. 359, which was recently
modified.
As of July 2008, Standard No. 359 does not use the 4-foot requirement. Sludge compliance is
now to be based on the sludge volume as a percentage of the total treatment volume. The revised
Standard states that sludge accumulation in the permanent treatment zone must be less than 50%
of the planned treatment volume. Also, there must be a minimum of 2.5 feet of liquid above the
sludge at the pump intake location. If either of these conditions is not met then sludge must be
removed or managed in accordance with an approved Plan of Action for Lagoon Sludge
Reduction (POA). A new sludge survey worksheet has been developed to calculate sludge and
treatment volumes to determine compliance.
Our records indicate that you have filed a Sludge POA for one or more of the lagoons at your
facility. Based on the changes to the sludge requirements in Standard No. 359, your lagoon(s)
may already be in compliance without any sludge removal. Using your lagoon design (or as -
built information) and current sludge survey measurements, complete the NEW sludge survey
worksheet. If you have any difficulty in locating or understanding your lagoon design
information, please contact your technical specialist or county Soil & Water office.
NorthCarolina
Aatum ly
Aquifer Protection Section 1636 Mail Service Center Raleigh, NC 27699-1636 Telephone: [phone]
Internet: www,ncwaterqualitv.org Location: 2728 Capital Boulevard Raleigh, NC 27604 Fax 1: [phone]
Fax 2: [phone]
An Equal OpportunitylAffirmative Action Employer- 50% Recyded710% Post Consumer Paper

Send both sludge survey worksheets, OLD and NEW, to the address below if you feel that your
lagoon(s) is in compliance and wish to withdraw your POA. Our staff will review the
information and notify you of our decision.
NCDENR — DWQ Animal Feeding Operations Unit
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
If you have any questions about the new sludge requirement, sludge survey worksheet, or any
related matter please feel free to contact the Animal Feeding Operations Unit staff at 919-733-
3221.
Sincerely,
Keith Larick, Supervisor
Animal Feeding Operations Unit
Enclosures
cc (w/o enclosures): Bladen County Soil and Water Conservation District
Fayetteville Regional Office, Aquifer Protection Section
AFO Unit Central Files - AWS090064

,4
a57-�-, 6/�fY
Animal Waste Management System Operator
WPCSOCC
NCAC 15A 8F .0201
FoRECEIVED
rm
APR 1.4 =
Ow-FAYETI'E uiFIMONALOFFICE
�L Iry gym. 1� vR3�Gc v�.5ir� y
Facility/Farm Name:
Permit #: A W S[o l0GD u [ Facility ID#: _-(Q� County:
Operator In Charge (OIC)
Name: ��_ Y 14ct� *1>uV+JVF—
First Middle - Last _ Jr, Sr. ete.
Cert Type / Number: l +�' 9S� �a, Work Phone:( +16)
Signature: Date: g �$
"I certify that I agnec esignation as the Operator in Charge for the facility noted. I understand and will abide by d c rules
and regulations pertaining to the responsibilities set forth in 15A NCAC 08F .0203 and failing to do so can result in Dist iplinary
Actions by the Water Pollution Control System Operators Certification Commission."
fB�ack-up Opetrator'' In Charge (Back-up OIC)
1..� W )Se—Ve.AP—
First Middle Last
(Optional)
A Sr, rte.
Cert Type / Number: AW 9,%,gqq q Work Phone: (
Signature: VAA Date:
"1 certify that I agree to my designation as Back-up Operator in Charge for the facility noted. I understand and will abide ty the
rules and regulations pertaining to the responsibilities set forth in 15A NCAC 08F .0203 and failing to do so can result ii
Disciplinary Actions by the Water Pollution Control System Operators Certification Commission."
Owner/Permittee Name:
Phone #:
Signature:
(Owner or authorized agent)
Mail or fax to: WPCSOCC
1618 Mail Service Center
Raleigh, N.C. 27699-1618
Fax:[phone]
Ravisrw arzoam
Fax#-.
(Retain a copy of this form for your records)
Date:

March 9, 2007
All In Farms, Inc.
All In Farms, Inc. (Yorick Nursery)
P.O. Box 535
Elizabethtown, NC 28337
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E. Director
Division of Water Quality
RECER/ED
MAR x .7 2007
OENR - }AYF ILLE REGIONAL OFRCE
Subject: Certificate of Coverage No. AWS090064
All In Farms, Inc. (Yorick Nursery)
Swine Waste Collection, Treatment,
Storage and Application System
Bladen County
Dear All In Farms, Inc.:
In accordance with your Notification of Change of Ownership received on February 19, 2007, we are
hereby forwarding to you this Certificate of Coverage (COC) issued to All In Farms, Inc., authorizing the
operation of the subject animal waste collection, treatment, storage and land application system in
accordance with General Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the All In Farms, Inc. (Yorick Nursery), located in Bladen County, with an animal
capacity of no greater than an annual average of 2600 Wean to Feeder swine and the application to land
as specified in the facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to
Wean or Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are
unneccessary, they may be replaced by an equivalent number of sows. Any of the sows may be replaced
by gilts at a rate of 4 gilts for every 3 sows.
The COC shall be effective from the date of issuance until September 30, 2009, and shall hereby void
Certificate of Coverage Number AWS090064 dated October 1, 2004. Pursuant to this COC, you are
authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed S
General Permit, it contains new requirements in a4
previous State General Permit. Enclosed for your
revised forms used for record keeping and reporting
and monitoring conditions in this permit.
Late General Permit. Since this is a revised State
Idition to most of the conditions contained in the
convenience is a package containing the new and
Please pad careful attention to the record keeping
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
Aquifer Protection Section 1636 Mail Service Center
tntemet: www.ncwate ual' .or Location: 2728 Capital Boulevard
An Equal Opportunity/Affirmative Action Employer- 50% Recyded110% Post Consumer Paper
Raleigh, NC 27699-1636 Telephone: [phone]
Raleigh, NC 27604 Fax 1: [phone]
Fax 2: [phone]
Customer Service: [phone]

The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
Iaws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this:permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 2H .0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall; R,consttuctad within the compliance boundary. Per NRCS standards a 100 foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, then an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Aquifer Protection Staff may be reached at [phone]. If you need additional information
concerning this COC or the General Permit, please contact Thomas Slusser at [phone].
Sincerely,
f�
D
-for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for al I ccs)
Fayetteville Regional Office, Aquifer Protection Section
Bladen County Health Department
Bladen County Soil and Water Conservation District
APS Central Files (Permit No. AWS090064)
AFO Files

o�oF w ArE9QG
> --f
Ray Beasley
Yorick Nursery
38 Turkey Oak Farm Rd
White Oak NC 28399
Dear Ray Beasley:
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
October 1, 2004
Alan W_ Klimek, P. E., Director
Division of Water Quality
RECEIVED
OCT 15 2004
OW - FAYETiE1l LLE REGONA! OWE
Subject: Certificate of Coverage No. AWS090064
Yorick Nursery
Swine Waste Collection, Treatment,
Storage and Application System
Bladen County
On June 11, 2004, the North Carolina Division of Water Quality (Division) issued a revised State General
Permit for swine facilities. The General Permit was issued in accordance with the directive of Senate Bill
733 (Session Law 2003-28).
In accordance with your application received on February 20, 2003 and in accordance with the directive
of Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to Ray
Beasley, authorizing the operation of the subject animal waste collection, treatment, storage and land
application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AWS090064 which expires October 1, 2004.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Yorick Nursery, located in Bladen County, with an animal capacity of no
greater than an annual average of 2600 Wean to Feeder swine and the application to land as specified in
the facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or
Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary,
they may be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a
rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Since this is a revised State
General Permit, it contains new requirements in addition to most of the conditions contained in the
previous State General Permit. Enclosed for your convenience is a package containing the new and
revised forms used for record keeping and reporting. Please pay careful attention to the record kegpins?
and monitoring conditions in this permit.
Aquifer Protection Section - Animal Feeding Operations Unit
1636 Mail Service Center, Raleigh, North Carolina 27699-1638
Phone: [phone] FAX [phone] / Internet: h2o.encstate.mus
An Equal Opportunity/Affirmative Action Employer - 50% Recycled110% Post Consumer Paper
ne
NorthCarolina
Nataallff

If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 2H .0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100 foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Duane Leith at [phone].
Sincerely,
zde�-I�
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG 100000)
cc: (Certificate of Coverage only for all cc's)
Fayetteville Regional Office, Aquifer Protection Section
Bladen County Health Department
Bladen County Soil and Water Conservation District
Permit File AWS090064
APS Central Files

OF VJA7 Michael F. Easley, Governor
Q William G. Ross Jr., Secretary
O North Carolina Department of Environment and Natural Resources
jICU) -7
Alan W. Klimek, P. E., Director
'i Division of Water Quality
a -7
May 1, 2003
Ray Beasley
Yorick Nursery
38 Turkey Oak Farm Rd
White Oak NC 28399
Subject: Certificate of Coverage No. AWS090064
Yorick Nursery
Swine Waste Collection, Treatment,
Storage and Application System
Bladen County
Dear Ray Beasley:
On April 28, 2003, the North Carolina General Assembly ratified Senate Bill 733 which directs the
Division of Water Quality (Division) to extend the expiration date of the Swine Waste Operation General
Permit AWG100000. Therefore, the General Permit has been re -issued by the Division to extend the
expiration date to October 1, 2004. During the period of this extension the Division will be working with
all interested parties on the development of a new version of the Non -Discharge General Permit.
In accordance with your application received on February 20, 2003 and in accordance with the directive
of Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to Ray
Beasley, authorizing the operation of the subject animal waste collection, treatment, storage and land
application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AWS090064 which expired on April 30, 2003_
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Yorick Nursery. located in Bladen County, with an animal capacity of no
greater than an annual average of 2600 Wean to Feeder swine and the application to land as specified in
the facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or
Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary,
they may be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a
rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until October 1, 2004. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC_ An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed_
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property. Ww
NCDEN t
Non -Discharge Permitting Unit Internet httpl/K2o.enr.state.nc.us/ndpu
1617 Mail Service Center, Raleigh, NC 27699-1617 Telephone [phone] Fax [phone]
Customer Service Center Telephone [phone]
An Equal opportunity Action Employer 50% recycled/10% post -consumer paper

Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per NRCS standards a 100 foot separation shall be maintained between water supply wells and any
lagoon or any wetted area of a spray field.
Please be advised that any violation of the terms and conditions specified in this COG the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]_ If you need additional information concerning
this COC or the General Permit, please contact Sue Homewood at [phone] ext. 502.
Sincerely,
lzde /_
for Alan W. KIimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
Fayetteville Regional Office, Water Quality Section
Bladen County Health Department
Bladen County Soil and Water Conservation District
Permit File AWS090064
NDPU Files

' Nutrient Management Plan For Animal Waste Utilization
12-20-2000
This plan has been prepared for:
Yorick Nursery
Virgil Ray Beasley
38 Turkey Oak Farm Rd.
White Oak; NC 28399
910-866-4955
This plan has been developed by:
Samuel G. Warren
NRCS/Bladen SWCD
122 Agriculture Service Center
Elizabethtown, NC 28337
910-862-3179 Ext. 3
Developer Signature
Type of Plan: Nitrogen Only with Manure Only
Owner/Manager/Producer Agreement
I (we) understand and agree to the specifications and the operation and maintenance
procedures established in this nutrient management plan which includes an animal waste
utilization plan for the farm named above. I have read and understand the Required
Specifications concerning animal waste management that are included with this plan.
01
Signature (owner)
Signature (manager or producer)
Date
Date
This plan meets the minimum standards and specifications of the U.S. Department of
Agriculture - Natural Resources Conservation Service or the standard of practices
adopted by the Soil and Water Conservation Commission.
Plan Approved By: a,,,, i�sjC. 2.-2-o—oo
Technical Specialist Signature Date
----------- ---- --------- ---- -- . ---- --.--
Preview Database Version 1.06 Date Printed: 12-20-2000 Cover Page 1

�1 Nutrients applied in'accordance with this plan will be supplied from the
following source(s): '
Commercial Fertilizer is not included in this plan.
S5
Swine Nursery Lagoon Liquid waste generated 496,600 gals/year by a
2,600 animal Swine Nursery Lagoon Liquid operation. This production
fiadlity has waste storage capacities of approxim!Lely 180 days.
Estimated Pounds of Plant Available Nitrogen Generated per Year
Broadcast
1144
Incorporated
1965
Injected
2165
Irrigated
1244
Actual PAN Applied
Year 1 j
1254
Notes:
In source ID, S means standard source, U means user defined source.
e4 g! bl�i�^a a
O K
�
Y / /
........ ................ . .
720188 Database Version 1.06 Date Printed: 12-19-2000 Source Page 1

The Waste Utilization table shown below summarizes the waste utilization plan for this operation. This plan provides an estimate of the number of acres of '
cropland needed to use the nutrients being produced. The plan requires consideration of the realistic yields of the crops to be grown, their nutrient requirements,
and proper timing of applications to maximize nutrient uptake.
This table provides an estimate of the amount of nitrogen required by the crop being grown and an estimate of the nitrogen amount being supplied by manure or
other by-products, commercial fertilizer and residual from previous crops. An estimate of the quantity of solid and liquid waste that will be applied on each field in
order to supply the indicated quantity of nitrogen from each source is also included.
A balance of the total manure produced and the total manure applied is included in the table to ensure that the plan adequately provides for the utilization of the
manure generated by the operation. Animal operations that generate liquid waste and utilize waste storage facilities (lagoons or holding ponds) may apply more or
less waste in any given year than is annually generated by the facility. In order to determine whether the plan adequately utilizes the waste produced by the facility,
the storage capacity table included in this plan should be reviewed to ensure that the design capacity of the storage facility is not exceeded during the planning
period.
Depending on the requirements of the crop and the nutrient content of the waste, some nutrients will likely be over or under applied if animal waste is being
utilized. Waste should be analyzed before each application cycle and annual soil tests are required if animal waste is being applied. Soil tests should be used to
balance the nutrient application amounts with the realistic yields of the crop to be grown. Nutrient management plans may require that the application of animal
waste be limited so as to prevent over application of phosphorous when excessive levels of this nutrient are detected in a field.
Waste Utilization Table
Year 1
Tract
Field
Source
I.D.
Soil Series
Total
Acre
Use.
Acres
Cro
RYE
RYE
Unit
Applic.
Period
Nitrogen
PA
Nutrient
Req'd
Comm.
Pert.
Nutrient
Applied
Res.
(lbs/A)
N
Applic.
Method
Manure
PA
Nutrient
Applied
Liquid
Manure
Applied
(acre)
Solid
Manure
Applied
(acre)
Liquid
Manure
Applied
(Field)
Solid
Manure
Applied
(Field)
N
N
Ibs/A
1000
1/A
tons
1000 nall
tons
103170
1
SS
1 Centen
0.7
0.6
rmuda Ha
•5.6
Tons
3/1-9/30
• 280
0
0
Irri .
280
111.8
0.0
67.1
0.0
103170
1
S5
Center
0.7
0.6all
Grain Overseed
1.0
Tons
10/1-3/31
50
0
0
Irri
50
20.0
0.0
12.0
0.0
103170
2
S5
Centen
1.0
1.0ruda
m s Ha
lermudagrass
05.6
Tons
3/1-9/30
• 280
0
0
Irri .
280
111.8
0.0
111.8
0.0
103170
2
S5
Centen
1.0
1.0all
GrainOverseed
1.0
Tons
10/1-3/31
50
0
0'
Irri .
s0
20.0
0.0
20.0
0.0
103170
3
S5
Centenary1.0
0.8Ha
05.6
Tons
3/1-9/30
• 280
0
0
Irri .
280
111.8
0-01
89.4
0.0
103170
3
85
Centenary
1.01
0.8
mall Grain Overseed
1.0
Tons
10/1-3/31
Sol
Ol
0
Irri .
50
20.0
0.01
16.0
0.0
103170
4
S51
Centenary
1.71
1.4
Oermudagrass Hay
1 05.6
1 Tons
3/1-9130
1• 2801
01
0
Irri .
280
111.8
0.01
156.5
0.0
.............................. ..........-- -- . .......
720188 Database Version 1.06 Date Printed: 12-19-2000
----------- ------------ ---
WUT Page 1 -

Waste Utilization Table
Year 1
Tract
Field
Source
I.D.
Soil Series
Total
I Acre
Use.
I Acres
Crop
RYE
RYE
Unit
Applic.
I Period
Nitrogen
PA
Nutrient
Req'd
I N
Comm.
Fert•
Nutrient
Applied
N
Res.
(lbs/A)
I N
Applic,
I Method
Manure
PA
Nutrient
Applied
Liquid
Manure
Applied
(acre)
Solid
Manure
Applied
(acre)
Liquid
Manure
Applied
(Field)
Solid
Manure
Applied
(Field)
I Ibs1A
1000
I ILI/A
I tons
1000 Wx
tons
103170
4
---S51Fentenary
1 1.71
1.4
mall Grain Overseed
1.0
ITons
1011-3131
1 50
01
0
1 Irri .
1 501
20-01
0.0
27.9
0.0
Lagoon Liquids
Total Applied, 1000 MlIons
501
Total Produced 1000 Icons
497
Balance 1000 gallons
-4
Ma
Manure Solids
Total Applied, tons
0
Total Produced tons
0
0
Balance tons
0
Notes: 1. in the tract column, symbol — means leased, otherwise, owned.
2. Symbol' means user entered data.
........................... ..... ... I.............. ......
720188 Database Version 1.06 Date Printed: 12-19-2000
W rr Page 2

The Irrigation Application'Factors for each field in this plan are shown in the following table.
Infiltration rate varies with soils. If applying waste nutrients through an irrigation system, you must apply
at a rate that will not result in runoff. This table provides the maximum application rate per hour that may
be applied to each field selected to receive wastewater. It also lists the maximum application amount that
each field may receive in any one application event.
Irrigation Antilication Factors
Tract
Field
Soil Series
Application Rate
inches/hour
Application AFWunt
inches
103170
I
Centengry
0.75
0.48
103170
2
Centomy
0.75
0.48
103170
3
Cen
0-75
0.48
I03170
4
Cen
0.751
0.48
.....................-----------.----------------------*--•-------------.....------------------------------------------------------
720188 Database Version 1.06 Date Printed: 12-19-2000 IAF Page 1

--The following Lagoon Sludge Nitrogen Utilization table provides an estimate of the number of acres needed f
or
Lagoon sludge contains nutrients and organic matter remaining after treatment and application of the effluent. At
clean out, this material must be utilized for crop production and applied at agronomic rates. In most cases, the
priority nutrient is nitrogen but other nutrients including phosphorous, copper and zinc can also be limiting. Since
nutrient levels are generally very high, application of sludge must be carefully applied.
Sites must first be evaluated for their suitability for sludge application. Ideally, effluent spray fields should not be
used for sludge application. If this is not possible, care should be taken not to load effluent application fields with
high amounts of copper and zinc so that additional effluent cannot be applied. On sites vulnerable to surface water
moving to streams and lakes, phosphorous is a concern. Soils containing very high phosphorous levels may also be
a concern.
Lagoon Sludge Nitrogen Utilization Table
Crop
Maximum
PA-N Rate
lb/ac
I Maximum Sludge
Application Rate
1000 gallac
Minimum Acres
5 Years Accumulation
Minimum Acres
10 Years Accumulation
Minimum Acres
15 Years Accumulation
Swine Nursery Lagoon Sludge - Standard
bu
150
13.16
6.62
- 13.24
19.95
LCormn20
ton R.Y.E.
300
26.32
3.31
6.62
9.93
an 40 bu
1601
14.041
6,20
12.41
18.61
------- ------ -------------------------------•------- ---------..------- -- ----------
720188 Database Version 1.06 Date Printed: 12-19-2000 Sludge Page 1

The Available Waste Storage Capacity table provides an estimate of the number of days of storage
capacity available at the end of each month of the plan. Available storage_ capacity is calculated as the
design storage capacity in days minus the number of days of net storage volume accumulated. The start
date is a value entered by the user and is defined as the date prior to applying nutrients to the first crop in
the plan at which storage volume in the lagoon or holding pond is equal to zero.
Available storage capacity should be greater than or equal to zero and less than or equal to the design
storage capacity of the facility. If the available storage capacity is greater than the design storage
capacity, this indicates that the plan calls for the application of nutrients that have not yet accumulated. If
available storage capacity is negative, the estimated volume of accumulated waste exceeds the design
storage volume of the structure. Either of these situations indicates that the planned application interval
in the waste utilization plan is inconsistent with the structure's temporary storage capacity.
Available Waste Storage Capacity
Source Name
Swine Nursery Lagoon Liquid
Design Storage Capacity (Days)
Start Date
09/30
180
Plan Year
Month
Available Storage Capacity a
1
1
91
1
2
74
1
3
85
1
4
117
1
5
148
1
6
180
1
7
180
1
8
180
1
9
180
1
10
160
1
11
141
1
12
116
* Available Storage Capacity is calculated as of the end of each month.
--...--- - -- --- - ------ ---- - -- - ----- .-----.----- - ---- -
720188 Database Version 1.06 Date Printed: 12-19-2000 Capacity Page 1

Required Specifications For Animal Waste Management
1. Animal waste shall not reach surface waters of the state by runoff, drift,
manmade conveyances, direct application, or direct discharge during
operation or land application. Any discharge of waste that reaches
surface water is prohibited.
2. There must be documentation in the design folder that the producer
either owns or has an agreement for use of adequate land on which to
properly apply the waste. If the producer does not own adequate land to
properly dispose of the waste, he/she shall provide evidence of an
agreement with a landowner, who is within a reasonable proximity,
allowing. him/her the use of the land for waste application. It is the
responsibility of the owner of the waste production facility to secure an
update of the Nutrient Management Plan when there is a change in the
operation, increase in the number of animals, method of application,
receiving crop type, or available land.
3. Animal waste shall be applied to meet, but not exceed, the nitrogen needs
for realistic crop yields based upon soil type, available moisture, historical
data, climatic conditions, and level of management, unless there are
regulations that restrict the rate of applications for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons per acre
per year. Waste may be applied to land eroding at more than 5 tons per
acre per year but less than 10 tons per acre per year provided grass filter
strips are installed where runoff leaves the field (see USDA, NRCS Field
Office Technical Guide Standard 393 - Filter Strips).
5. Odors can be reduced by injecting the waste or by disking after waste
application. Waste should not be applied when there is danger of drift
from the land application field.
6. When animal waste is to be applied on acres subject to flooding, waste
will be soil incorporated on conventionally tilled cropland. When waste is
applied to conservation tilled crops or grassland, the waste may be
broadcast provided the application does not occur during a season prone
to flooding (see "Weather and Climate in North Carolina" for guidance).
7. Liquid waste shall be applied at rates not to exceed the soil infiltration
720188 Database Version 1.06 Date Printed: I2-19-2000 Specification Page 1

rate such that runoff does not occur offsite or to surface waters and in a
method which does not cause drift from the site during application. No
ponding should occur in order to control odor and flies.
8. Animal waste shall not be applied to saturated soils, during rainfall
events, or when the soil surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner
that the crop is not covered with waste to a depth that would inhibit
growth. The potential for salt damage from animal waste should also be
considered.
10. Nutrients from waste shall not be applied in fall or winter for spring
planted crops on soils with a high potential for leaching. Wastelnutrient
loading rates on these soils should be held to a minimum and a suitable
winter cover crop planted to take up released nutrients. Waste shall not
be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11. Any new swine facility sited on or after October 1,1995 shall comply with
the following: The outer perimeter of the land area onto which waste is
applied from a lagoon that is a component of a swine farm shall be at
least 50 feet from any residential property boundary and canal. Animal
waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer that 25 feet to perennial waters.
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other
than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and
public right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways,
or wetlands by a discharge or by over -spraying. Animal waste may be
applied to prior converted cropland provided the fields have been
approved as a land application site by a "technical specialist". Animal
waste shall not be applied on grassed waterways that discharge directly
into water courses, and on other grassed waterways, waste shall be
... -
720188 Database Version 1.06 Date Printed: 12-19-2000 Specification Page 2

applied at agronomic rates in a manner that causes no runoff or drift_
from the site.
16. Domestic and industrial waste from w$shdown facilities, showers, toilets,
sinks, etc., shall not be discharged into the animal waste management
system.
17. A protective cover of appropriate vegetation will be established on all
disturbed areas (lagoon embankments, berms, pipe runs, etc,). Areas
shall be fenced, as necessary, to protect the vegetation. Vegetation such
as trees, shrubs, and other woody species, etc., are limited to areas where
considered appropriate. Lagoon areas should be kept mowed and
accessible. Berms and structures should be inspected regularly for
evidence of erosion, leakage, or discharge.
18. If animal production at the facility is to be suspended or terminated, the
owner is responsible for obtaining and implementing a "closure plan"
which will eliminate the possibility of an illegal discharge, pollution, and
erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected
on a regular basis to prevent breakdowns, leaks, and spills. A regular
maintenance checklist should be kept ' on site.
20. Animal waste can be used in a rotation that includes vegetables and other
crops for direct human consumption. However, if animal waste'is used
on crops for direct human consumption, it should only be applied
pre -plant with no further applications of animal waste during the crop
season.
21. Highly visible markers shall be installed to mark the top and bottom
elevations of the temporary storage (pumping volume) of all waste
treatment lagoons. Pumping shall be managed to maintain the liquid
level between the markers. A marker will be required to mark the
maximum storage volume for waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested
at least annually at crop sites where waste products are applied. Nitrogen
shall be the rate -determining nutrient, unless other restrictions require
. -- ---------------- --------------- ice' ----------------
720188 Database Version 1.06 Date Printed: 12-19-2000 S ification Page 3

zy '
.waste to be applied based on other nutrients, resulting in a lower
application rate than a nitrogen based rate. Zinc and copper levels in the
soils shall be monitored and alternative crop sites shall be used when
these metals approach excessive levels. pH shall be adjusted and
maintained for optimum crop production. Soil and waste analysis
records shall be kept for a minimum of five years. Poultry dry waste
application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a
minimum of five years.
23. Dead animals will be disposed of in a manner that meets North Carolina
regulations.
---------------------------- -- --------------
720188 Database Version 1.06 Date Printed: 12-19-2000 Specification Page 4

Wettable Acres. Determination Certification
Name of Facility: Vo f ► c k tr
Owner(s) Name:
Mailing Address: 8
y Number:- 4:1;34�
No?10-8(- 4
By signing this form, the facility owner and Technical Specialist acknowledge the completion of the
Wettable Acres Determination. All necessary Wettable Acre Determination Field Data Sheets and
calculations were completed to conduct a Wettable Acre Determination. The facility's Waste
Utilization Plan has been amended as necessary to reflect actual wetted acreage. A copy of all_
worksheets, calculations, and other Wettable Acres Determination documents, along with the
applicable Waste Utilization Plan and Wettable Acre Determination Certification will be filed with
the local Soil and Water Conservation District. A copy will also be kept on site with the Certified
Animal Waste Management Plan. Any future modifications must be approved by a technical
specialist and filed with the Soil and Water Conservation District prior to implementation. If any
modifications to the existing irrigation system or any new irrigation equipment was required to
adequately address the waste management needs of this facility, an Irrigation Specialist or
Professional Engineer has certified the design and installation below.
Owner Name:
Owner Signature: Date: f 1a o0
Technical Specialist Name:.
"Technical Specialist Signature:
: iZ-11-7_o¢a
- — . If assisted by an 1Errigatiori Specialist or Professional EmgineeF glease read and sigh- below:
Animal waste application equipment has been designed or modified to apply waste as necessary to
accommodate the waste management plan and according to NRCS Standards. Animal waste —
application equipment has Ybeen installed according to NRCS_Standards and is.ready_ for use
Irrigation SD6HaWtfPF-Name:_--_-
_= Tari anon Special st%PE gnature: - - Date:.
Submit this I:oran t--
_ Attn: Son-
_ Non-Discharge-C6mpiraace - �-
-- of Wit(Mi
_ _ _ - ._ 1617-Mail. 3er�i
= ---

D t- cJiC
FseW Data s4 s�«+, za�
5twtiasvy 5pris�icIoAG�ea
• CAWMP Weuabk A=
STATIONARY SPRUWLER SYSTEM
1. Sprinkler make and mmW er
2. Sprinkler nozzle size 3 a inch]
3. Lateral spacing �ad — [feet] by Sprinkler spacing along lateral [feet]
4. Operating pressure at the sprinkler m [Psi]
S. Sprinkler wetted diameter DS [feetJ- measured or V,,_ determined from chart
6. Number of sprinklers operating at one time f D r
7. Total number of sprinklers or sprinkler locations in the system �J -.:5 5 �G �a^�
aetrG�
Exterior Sprinklers: part circle full circle
Interior Sprinklers: full circle
Sprinkler Locations Permanently Marked: ��es no
S. Supply Line Permanent Pipe X Portable Pipe
**9. Lateral line size Z [inch]. If more than one size, indicate size and approximate
length of each. Can be done on the map.
Lateral line length [feet]. 9-ongest lateral)
**I 1- Supply line size A _ [inch]. If more than one size, indicate size and
approximate length of each. Can be done on map.
* * 12. Supply line length [feet]. Maximum purnping distance.
** l3. Pump make and model number
** 14. Pump capacity [gpm]
* * 15. Engine make and model number or
** 16. Electric motor horsepower and rpm S [hp] [rpm]
ote: It is strongly recommended that sprinkler wetted diameter be field
measured. It should be done on the longest lateral about half -gray down the
lateral.
* Locate each sprinkler or sprinkler location on the map. Indicate whether full -circle or
part -circle Show the location of the supply line. Irrigated acres will be determined by
lateral line, by zone or by field.
* * Optional data, furnish where possible
* * * Information furnished by
and/or
Signature of owner or Facility ReprAentative
Printed N �Ow=Mcility Rep tative
Date 1 (D DO -
Date
Signature of Technical Specialist
Printed Name of Technical Specialist
*** Only the person or persons collecting the data should sign the data sheet x,

4
Ono my
011,
WC poly -�T
Ilk
. . . . . . . . . . . . .

�f�}�" _ �t1ys j.•lF'�Y�yy y,YfyY{C s(r� -h . � .. r _ '..
�s• J . •: J _. J ' d r�rh l :_, � 1 a •r;,• yl.; :;
``?k r't1 4 firlat 1 L e 41i _ l r ilk +r - 1 a{-^r t+ 4'}''fiQi t.• M+�.y.-r r1` Y.
f• ••n( ..�':1,}J3d rr .F. µ
},r.�r
J{ fir, I C- k`]� "1 : .. 'r.. .. �-��y+r' 4S♦. '��i;l��"'S^•�?� +�.�i.• �1y�.
y` rrl. +'�`14rrl l t�\i. ,�r�l 1. .� `" , i „'+'•ht`r a'•r',Jh�f'-}wi.Yr �''r'^1 �?. 'nl.�"'>,
�,t a C rir k _�f ��`,lrG I � � " � f `!. �' r � ... .' ..r.+ - ri r' +�." � :••, 1:. � Ty, •► ni° � .
Tv
qp
r ..J ;}' t .•t ;+ err �•~ I i•i
ry 4✓rS h S1 'r" k ' ,y d�_ Jil}'r - �i r.;l
`S`�'� '�' ;A � �v^]21rNe•Y• "Srxi`fllr ar�•iJ' � �' •"' •.? - er'r � } 1.�,qq :�i �, ... - 1 � /
Qi
++�i. C,y ysr� t 1 (./1 .' 1 dr• 4 � �'Y.I
•"� tr *M Vr. ff f I. L�' fa •Y R � � '_�C• _ ry Y_ ,> k!R r
y i � f7s 1h• J 7 {I I ' .. • II/1 _ >A4y rN 1n-e` � �f� � yl.irtr•�
��_ r -S � �� 'a { r �� +t � reS ! -�• s� �"R• g f- f`t
• a��+� ���,t:��,Z{ t� ICY`" k+ q ap;' l ' � r'�� y�: 1-i r �i ''".�.��1� i,°•: i°' � ' ,'� � . ' '.
11t_6; ii.Yk Fi+..;n - e 5(: r..� j'r��•";.
1+ra
�!•'
y t 1�'" �.1 n ,,e �",,�,(� r L r� I i�, s. S t� " '•' \�. .-.� J a t
17
cv y r J j 1y j } f 1 _ I r w7r f`ti / pjr
.. '� rt 'W �-ry r iTY' S A, � _ G. I S l,. / 1 I { Y' P„ 1w,ta} «Y•'�.
wll �,p•r4�r�}}�� 1ywh1--,.t-: r" j. <hYr ..P, 4 rl' f^[t' C5 � - + I
=:
yJ�� a iK�* �`s++kR,'�". }r l lff _ � {��1 ' � I - . •+B'i'IC^ _ ,
t
�'r , w�iJi ;�, 7�`1J+� ';- t '.•' ij
r ��
- �,'tt�-f ' t � `.i�i`� r r 4 �5 .' , .. .. _ ' �o ` .;.*s�,� r' ,� �4r c .,•i . r 'v • �
.xi J'.y r lja r
_I}- r i � ♦ � a -. •�ry`xr" ry kkk••••„••••�i i r. i, ti.. 4 R•
L•r {
Cl
L 7a
Y t n si'%•. td`hf.i�`. ` 91...•r Lt r } I F � ir 1+
rj5i, I it c �J•, a `+rc i
"MUM
VGA
r yl f'}' •�"L - I.. J. `J f . ! I ;1 L %•17
r'"s`` �'z� •f yy!}r�*('^.r y� t r J f Y 4,. s
�'I'FF1'y�
visit. !'j�Ew 15 r " �, ri��• - �, 1,+:.
Yk s l JL
yr8«I 1 .J 1` ;1��' F� � f '$ 'i� •r•�s,,. Jl � - -t.[ 4 J. .. µ -
L I�f 4 -.
•1 1.E'i +�i,r a / `J ���4 y+• - 4 ' � 4
.ri'�y�' �'�, c j �i 'i,�b �`' Pp� 1% � �ti ' r 1 �-, - ` �. a0�4. '�• � �" 's 'u
L. IF riMt Sf kt-! i'^ , t� 1 T,'{. Y 7 • t ` �► r t t :i ,,r °
�r. •+ �d FL` y ��� C r�'.51, y qq 'y^��t � w. ^) •�.� r t
• t r 'I k Al
0� ° '•vx 7 -*R r' �. �- I 'S sJ r,�+` +
t ;• �r{'li1 a -I�K4 ' I �:en a� t4r � r s TII t."' ., J � ��.
♦ P r,t 1 y„�r4 J� r j -r iY i �{- r yr'
I •'�i) 4'F L� � Or

Stationary SprWc!errGun Camqutu;enat W-Wkth-c: - 2::c ar
----------STATIONARYSPRINKLER /GUN SYSTEM --------------
COMPUTATIONAL WORKSHEET
-I-Farm Number (Identification) --
Field Number (Identification)
2-.----Irrigation System Designation )yL Existing Irrigation System - -
New / Expanded Irrigation System
3. Number of Stationary Sprinklers n Interior sprinklers f- Exterior sprinklers
4. Wetted Diameter [feet] From field data sheet
5. Spacing 60 Sprinkler spacing along lateral [feet]
S 7 Sprinkler spacing as percentage of wetted diameter
6. Sprinkler Pattern Multiple Laterals J( Single Lateral
Excessively spaced Sprinklers
7. Read the irrigated area per sprinkler for the given wetted diameter from the appropriate table and column
based on pattern, spacing, and sprinkler location.
Acres per Interior sprinkler from Table Column
f Z,� Acres per Exterior sprinkler from Table Column _f--
S. Multiply the tabulated irri¢ated acreage value per sprinlder by the number of sprinklers of each category M
the field. Sum all of these and this is the total irrigated acreage for the field.
(a) Acres per Interior Sprinkler X T Sprinklers = Acres
, /19 (b) Acres per Exterior Sprinkler X 5 4; Sprinklers = Acres
D.� Total Wettable Acre for field (Sum: Sa + 8b)
Wettable Acre Computational Workcsheet Completed by: Lys A)'�--, �C DateJ2- ed

e 0.crc-...._. _---.---- _ _ - SLatI0i1 SpdOlder _=C.Omputuic'gUl Wwt- Tr! _2-.r
-STATIONS Y. SFRIN11aER /GUN SYSTEM
__- - - - - - - COMPUTAT1U1NAL W4RKSHEET
v== , fariirNumber (Identifications Field Number (Identification)
2 gation-System Designation = ^Ezesting Irrigation System - -----' ---_ —
New / Expanded Irrigation System
3. Number of Stationary Sprinklers K Interior sprinklers 7 Exterior sprinklers
4. Wetted Diameter [feet] From field data sheet
5. Spacing aAy Sprinkler spacing along lateral [feet]
b. Sprinkler Pattern
S 7 Sprinkler spacing as percentage of wetted diameter
74 Multiple Laterals
Excessively spaced Sprinklers
Single Lateral
7. Read the irrigated area per sprinkler for the given wetted diameter from the appropriate table and colurnn
based on pattern, spacing, and sprinkler location.
.6 9 /
Acres per Interior sprinkler from
Fable 3
Column —d-
7
Acres per Exterior sprinkler from
Table 3
Column e_
8. Multiply the tabulated irrigated acreage value per sprinkler by the number of sprinklers of each category in
the field. Sum all of these and this is the total irrigated acreage for the field.
Vqr - (a) Acres per Interior Sprinkler X
,2.
Sprinklers
= O 8 Acres
, ► 17 (b) Acres per Exterior Sprinkler X
I
n Sprinklers
= &, 99_- Acres
�D Total Wettable Acre for field (Sum: 8a + 8b)
Wettable Acre Computational Worksheet Completed by ' cam- G. CGry�c Date:

New /-Expanded Irrigation System
3. Number of Stationary Sprinklers # Interior sprinklers 4/ � # Exteriors rinklers
4. Wetted Diameter
5. Spacing
/ dS - [feet] From field data sheet
4 0 Sprinkler spacing along lateral [feet]
f 7 Sprinkler spacing as percentage of wetted diameter
6. Sprinkler Pattern -X Multiple Laterals
Excessively spaced Sprinklers
Single Lateral
7. Read the irrigated area per sprinkler for the given wetted diameter from the appropriate table and column
based on pattern, spacing, and sprinkler location.
p q j
Acres per Interior sprinkler from
Fable _ 3 _
Column
1 f
Acres per Exterior sprinkler from
Table 3
Column G
8. Multiply the tabulated irrigated acreage value per sprinkler by the number of sprinklers of each category in
the field. Sum all of these and this is the total irrigated acreage for the field.
,p _
{a) Acres per Interior Sprinkler X
3 Sprinklers
= 0 , Z Acres
,117
(b) Acres per Exterior Sprinkler X
Sprinklers
= 6) , 53 Acres^
D Total Wettable Acre for field (Sum: Sa + Sb)
l 6 ��C �2'i_14,
Wettable Acre Computational Worksheet Completed y: Date: `7

WORKS EE-1
-
eicatzon -_ - -- Meld Numberntti}rati _-
..- -
- -- - -- - — _ -- _--_ -
- ymHeSYgilatlf3n_,- 'EZ6Li�lgFrigatlon System
New / Expanded irrigation System
3. Number of Stationary Sprinklers # Interior sprinklers # Exterior sprinklers
4. Wetted Diameter bS [feet] From field data sheet
5. Spacing 10 Sprinkler spacing along lateral [feet]
Sprinkler spacing as percentage of wetted diameter
6. Sprinkler Pattern Multiple Laterals Single Lateral
Excessively spaced Sprinklers,
7. Read the irrigated area per sprinkler for the given wetted diameter from the appropriate table and column
based on pattern, spacing, and sprinkler location.
. 1 Z
Acres per interior sprinkler from
Fable
Column
. 3
Acres per Exterior sprinkler from
Table
Column
S. Multiply the tabulated irrigated acreage value per sprinkler by the number of sprinklers of each category in
the field. Sum all of these and this is the total irrigated acreage for the field.
(a) Acres per Interior Sprinkler X a 4 Sprinklers = t).37 Acres
�3 (b) Acres per Exterior Sprinkler X -1 # Sprinklers = , 0 2-- Acres
Total Wettable Acre for field (Sum: 8a + 8b)
Wettable Acre Computational Worksheet Completedb .�� , �G�+-}-� �- C. Date: 1 L ' y: -Zavo �.

State of Mrth Carolina
Department of Environment
and Natural Resources RECEI
VED
Q
Division of Water Quality R V ED
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
RAY BEASLEY
YORICK NURSERY
38 TURKEY OAK FARM RD
WHITE OAK, NC 28399
Dear Ray Beasley:
M A g 1 7 2000
REG. p�10EE
March
14, 2000
,Tk* V
NCDENR
NORTH CAROLINA DEPARTMENT Orr-
ENViRONMENT ANb NATURAL RESOURCES
Subject: Certificate of Coverage No. AWS090064
Yorick Nursery
Swine Waste Collection, Treatment,
Storage and Application System
Bladen County
In accordance with your application received on January 29, 2000, we are forwarding this Certificate of
Coverage (COC) issued to Ray Beasley, authorizing the operation of the subject animal waste collection,
treatment, storage and land application system in accordance with General Permit AWG100000. This
approval shall consist of the operation of this system including, but not limited to, the management of
animal waste from the Yorick Nursery, located in Bladen County, with an animal capacity of no greater
than 2600 Wean to Feeder and the application to land as specified in the Certified Animal Waste
Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
The facility's CA A1`MP meets all requirements in place at the time of certification. However, it appears
that the irrigation system on site may not adequately cover all acreage listed in the Waste Utilization
Plan. The owner should address this inconsistency as soon as possible.
Please note condition number ten of the general permit that states that trees, shrubs, and other woody
vegetation shall not be allowed to grow on the lagoon/waste storage pond embankments and that all trees
shall be removed in accordance with good engineering practices.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Certificate of Coverage AWS090064
Yorick Nursery
Page 2
-W db.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive refief.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This request
shall be made within 30 days of notification by the Division.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the DWQ prior to a name change or change in ownership.
If any parts, requirements, or Iimitations contained in this COC are unacceptable, you have the right to
apply for an individual non -discharge permit by contacting the engm
ineer listed below for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
The subject farm is located in the Fayetteville Regional Office. The Regional Office Water Quality Staff
may be reached at [phone]. If you need additional information concerning this COC or the
General Permit, please contact Susan Cauley at [phone] ext. 546.
Sinc�ely,
Kerr T_ Stevens
cc: (Certificate of Coverage only for all cc's)
Bladen County Health Department
Fayetteville Regional Office, Water Quality Section
Bladen County Soil and Water Conservation District
Permit File
NDPU Files

State of North Carolina
Department of Environment
and Natural Resources
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
CERTIFIED MAIL
RETURN RECEIPT REQUESTED
Ray Beasley
Yorick Nursery
38 Turkey Oak Farm Rd
White Oak NC -28399
Dear Ray Beasley:
1 Iffl?OW'AIT
•
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
November 6, 2000
UE I VD
NOV 0 8 2000
FlyyL f'r`EVILLE
REG. OFFICE
Subject: Notification for Wettable Acre Determination
Animal Waste Management System
Yorick Nursery
Facility Number 9-64
Bladen County
A letter dated January 15, 1999 was sent to advise you about concerns associated with Certified Animal
Waste Management Plans and the method by which the irrigated acres within the plans were calculated. Only
the acres that are wetted can be credited in the waste management plan as receiving waste application. Any
acreage within the plan that can not be reached by waste application equipment can not be used as part of your
plan.
An evaluation by Audrey Oxendine on 5/3/99 was made to review the actual number of acres at your
facility that receive animal waste during land application. The evaluation of your facility has yielded one of
the following two results as indicated by the box marked with an "X".
Category 1:
The evaluation of your facility could not be completed due to a lack of information. Please
contact your Technical Specialist to assist in providing Trent Alien the necessary
information to potentially exempt your facility from undergoing a complete wettable acre
determination. Please submit this information to Trent Allen, at 225 Green Street, Suite
714, Fayetteville, NC 28301, within in 90 days of the receipt of this letter. If you have any
questions please contact Trent Allen at [phone]. If within 90 days you are unable
to provide Trent Allen with the information you are automatically required to complete
a Wettable Acre Determination as described by Category 2 below, within 180 days
of receipt of this letter.
1617 Mail 5er-klce Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Aftirmative Action Employer 50% recycled/10% post -consumer paper

Notification for Wettable Acre Determination
Animal Waste Management System
Page 2
Category 2:
❑ Your facility has been identified by the Department of Environment and Natural Resources
as a facility that may have overestimated the number of acres actually receiving animal
waste. Therefore, some or all of your fields may be exceeding the allowable loading rates
set in your Certified Animal Waste Management Plan.
In order to resolve this issue, please contact a designated Technical Specialist to have him
or her conduct a Wettable Acre Determination for your facility. The Technical Specialist must
be one that has been approved by the Soil and Water Conservation Commission to conduct
Wettable Acre Determinations. Many Technical Specialist with the N.C. Cooperative Extension
Service, the Soil and Water Conservation Districts, the Natural Resources Conservation
Service, and the Division of Soil and Water Conservation have received this special
designation. You may also contact a private Technical Specialist who has received this
designation, or a Professional Engineer.
All needed modifications to your Animal Waste Management System must be made and
the Wettable Acres Determination Certification must be returned to DWQ within the next
180 days. If the needed modifications are not made and if the form is not returned within the
required time, DWQ will be forced to take appropriate enforcement actions to bring this facility
into compliance. These actions may include civil penalty assessments, permit revocation,
and/or injunctive relief.
Once a Wettable Acre Determination has been completed, a copy of the attached Wettable
Acre Determination Certification must be submitted to the address listed on the form. Please
note that both the owner and the Technical Specialist must sign the certification. A copy of all
the Wettable Acre Determination documentation that applies to your Waste Utilization Plan
must be kept at your facility. DWQ and the Division of Soil & Water Conservation Staff will
review all documentation during their annual visit of your facility. An additional copy must by
kept on file at the local Soil & Water Conservation District Office. Please note that if you install
or modify your irrigation system, a designated Irrigation Specialist or a Professional Engineer
must also sign the Wettable Acre Determination Certification.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Sonya Avant of our
Central Office staff at [phone] ext. 571.
Sincerely,
Kerr T. Stevens
cc: Fayetteville Regional Office
Bladen County Soil and Water Conservation District
Facility File
Murphy Family Farms

Rec �_- State of North Carolina
GCEIV 4epartment of Environment and Natural Resourco rR�CE
�AA� i 7 2000 Division of Water Quality Rnf��r,t'ys �0
Non-Discharbe Pen -nit Application Form L/QN N
FAYETTEVILLE (THIS FORM MAY BE PHOTOCOPIED FOR USE AS AN ORIGINAL) 9 C(i(.0
REG.OFFICCeneral Permit - Existing Animal Waste Opera 'a .h
The following questions have been completed utilizing information on rile with the Division. Please review the
information for completeness and make any corrections that are appropriate. If a question has not been completed by
the Division, please complete as best as possible. Do not leave any question unanswered.
1. GENERAL INFORMATION:
1.1 Facility Name: Yorick Nursery_
1.2 Print Land Owner's name:
1.3 Mailing address. 38 Turkey Oak Farm Rd
City, State: White Oak NC Zip: 2
Telephone Number (include area code): 866-5440
1.4 County where facility is located: BI
1.5 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads_ Please include a copy
of a county road map with the location of the farm identified): Farm location: On Highway 53 east approx. 5 1/2 miles
from Elizabethtown - Hwy 53 at Yorick.
1.6 Print Farm Manager's name (if different from Land Owner):
1.7 Lessce's Integrator's name (if applicable; please circle which type is listed): Murphy Family Farms
1.8 Date Facility Originally Began Operation: 01/01/92
1.9 Datc(s) of Facility Expansion(s) (if applicable):
2. OPERATION INFORMATION:
2.1 Facility No.: 09 (county number); 64 (facility number).
2.2 Operation Description: Swine operation
Wean to Feeder
2600- Certified Design Capacity
Is the above information correct?yes; E]no. If no, correct below using the design capacity of the facility
The "No. of Animals" should be them mum number for which the waste management structures were designed.
Type of Swine No. of Animals Type of Poultry No. of Animals Tvne of Cattle No. of Animals
0 Wean to Feeder 0 Layer 0 Dairy
0 Feeder to Finish 0 Non -Layer 0 Beef
0 Farrow to Wean (# sow) 0 Turkey
0 Farrow to Feeder (# sow) _
0 Farrow to Finish (# sow)
Other Type of Livestock on the farm: No. of Animals:
FORM: AWO-G-E 5/28/98 Page 1 of 4 09 - 64

3.
2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): 4 Required Acreage (as listed in the AWMP): 4
2.4 Number lagoon -storage ponds (circle which is applicable):
2.5 Are subsurface drains present within 100' of any of the application fields? YES or NO (please circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES NO (please circle one)
2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, NRfSSLtndards, etc.) (Swine Only)
YE�r . NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited?
What was the date that this facility's land application areas were sited'?
REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item_
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit application
for animal waste operations.
The CAWMP must include lltc fallowing components. Sunte' of these components may not
have been required at the time the facility_ • was certified but shutdd be added to the
CAWMP for pernnittinr; Purposes:
3.3.1 The Waste Utilization Plan (WUP) must include the amount ol'Plant Available
Nitrogen (PAN) produced and utilized by the facility_
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application.
3.3.4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP_
3.3.7 The PAN applied to every land application field.
3.3.8 The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.3.10 A site schematic.
3.3.1 1 Emergency Action Plan.
3.3.12 Insect Control Checklist with chosen best management practices noted.
3.3.13 Odor Control Checklist with chosen best management practices noted.
3.3.14 Mortality Control Checklist with the selected method noted.
3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility_
3.3.16 Operation and Maintenance Plan.
If your CAWMP includes any components not shown on this list, please include the
additional components with your submittal.
Applicants Initials
}
L/
FORM: AWO-G-E 5/28/98 Page 2 of 4 09 - 64

Facility Number: 09 - 64
Facility Name: Yorick Nursery
4. APPLICANT'S CERTIFICATION:
RECEIVED
WATEER Q t� ?y SEC f i0N
'JAN 2 9 2`0
N1n-D!wh&19e PermitUng
/t
I, � r-+ . - Cf� (Land Owner's name listed in question L2), attest that
this application for _ L1 •-) r- ; S- L-1 . (Facility name listed in question 1.1)
has been reviewed by me anAis accurate and complete to the best )f my knowicd-c. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be rctur� e as i lete.
Signature cam_ m Date l — 7ZI-c,
5. MANAGER'S CERTIFICATION: (complete only if different from the Land Owner)
1, (Manager's name listed in question 1.6), attest that this
application for (Facility name listed in question I.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be returned as incomplete.
Signature Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO TI lE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE. PERMITTING UNIT
1617 :\TAIL SERVICE CENTER
RALEIGH, NORTH CAROLINA 27699-1617
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
FORM: AWO-G-E 5/28/98 Page 3 of 4 09 - 64

A
­v .. ­." "-,
m
ZA
Li
ro
. . . . . . . . . . . . .
Ni 4
1*1:
A"I
if t
IL
fax.
xl�

rA

F:Lxtstkg,-'or NeN
ene al lnformatic
Name of Farm:
Owners) Name:_
Mailing Address:
Farm Location:
RECE VED
Animal Waste Management Plan Certification WATER QtJAL:,.T `SECTION
(Please type or print all information that does not require a signature)
or Expanded
Latitude and Longitude:
lease circle one
County Farm is located
78 � 3 , J-0 "
Facility No: -- e`l'
Phone No: _""g
t l _
Please attach a copy of a county road map with location identified and describe below (Be specific: road
names, directions, rnilepost, etc.): -AIL 73 — 3?1r►1. _c�J�S� tr� u� 7� 1 4''n
QperatioI3 Des ri ti n:
TWp e of Swine No. of Animals
ean to Feeder
:1 Feeder to Finish
J Farrow to Wean
J Farrow- to Feeder
i Farrow to Finish
Type of Poultry No. ofAnimals Type of Cattle No. of Animals
Z) Layer v Dairy
t Pullets 3 Beef
. .QrherJjvpe of Livestock: z Number of Animals:
Expanding Operation On!}
Previous Design Capacity: Additional Design Capacity ry
Tonal Design Capacity: —
Acreage A%-ailable for Application_ Rewired Acreage:
Number of Lagoons I Storage Ponds : Total Capaci I Z (_ (S 3 Cubic Feet (0)
Are subsurface drains present on the farm: YES or N (please circle one)
If ITS: are subsurface drains present in the area of the LAGOON or SPRAY FIELD (please circle one)
***#******x*xxx********************************************#,k+*********************
Owner / Manager Agreement
1 (we) Verify that all the above information is correct and will be updated upon changing. l (we) understand the operation and
maintenance procedures established in the approved animal waste management plan for the farm named above and will
implement these procedures. 1 (we) know that any expansion to the existing design capa.ity of the waste treatment and
storage system or construction of new facilities will require a new certification to be submitted to the Division of
Environmental Management before the new animals are stocked. 1 (we) understand that there must be no discharge of animal
waste from the stora0e or application system to surface waters of the state either directly through a man-made conveyance or
from a storm event less severe than the 25-year, 24-hour storm and there must not be run-off from the application of animal
waste. i (we) understand that run-off of pollutants from lounging and heavy use areas must be minimized using technical
standard; developed by the Natural Resources Conservation Service. The approved plant will be filed at the farm and at the
office of the local Soil and Water Conservation District. l (,. e) know that any modification must be approved by a technical
specialist and submitted to the Soil and Water Consen•ation District prior to implementation. A change in land ownership
requires written notification to DEM or a new certification (if the approved plan is changed) within 60 days of a title transfer.
Name of Land Owner :
� r
Signature: l
Name of Nlanager(if different from owner):
Date: 9-!
Date:
Signature:
A-%N"C -- January 1.1997 1

Technical Specialist Certification
LAs a ttchni_-al specialist designated by the North Carolina Soil and Water Conservation Commission pursuant to 15A
NCAC 6F .0005. 1 certify that the animal waste management system for the farm named above has an animal waste
manascmcnt plan that meets or exceed standards and specifications of the Division of Environmental Management (DEM)
as specified in 15A ?NCAC 2H.0217 and the USDA -Natural Resources Conservation Service (MRCS) and/or the North
Carolina Soil and Water Conservation Commission pursuant to 15A NCAC 2H.0317 and 15A NCAC 6F .000)-.0005. The
following elements are included in the plan as applicable. NN'hile each category designates a technical specialist who may
sign each certification (SD. Sl. WILT., RC, 1). the technical specialist should only certify parts for which they are technically
competent.
IL Certification of Desigiz
A) Collection, Storage. Treatment Svstern
Check t e appropriate box
Existing facility without retrofit (SD or NNW)
Storage volume is adequate for operation capacity; storage capability consistent with waste utilization
requirements.
U Neu expanded or retrofitted facility (SD)
Animal waste storage and treatment structures, such as but not limited to collection systems, lagoons and ponds,
have been designed to meet or exceed the minimum standards and specifications.
Name of Technical Specialist (Please Print): Samuel G. Warren,
Affiliation: USDA - Natural Resources Conservation Service
Address(AQency)�2.2 Ag. Service Center, Elizabethtown Phone No.:
Signature:,
B) Land Application Site (NN UP)
The plan provides for minimum separations (buffers): adequate amount of land for waste utilization; chosen crop is
suitable for waste management; hydraulic and nutrient loading rates.
Dame of Technical Specialist (Please Print): SarT,u�_l G. Warren, GL
Affiliation: USDA - hatut,i rr;uurchs Cunseryoi;6f1 Stiivice
Address(P
Signature:
C) Runoff Controls from Exterior LLc is
Check the appropriate box
Facility without exterior lots (SD or NNW or RC)
This facility does not contain any exterior lots.
ne No.. 910-862-6y36
Facility With exterior lots (RC)
Methods to minimize the run off of pollutants from lounging and heavy use areas have been designed in
accordance with technical standards developed by NRC5.
Name of Technical Specialist (Please Print): Samuel G. Warren, DC
Affiliation:
��S�ti - I�scu,ai rii'Sv;rccS Cunszr�;t,ti�:r St:r�iCtr
12 Ag. Service Center, Elizabethtown, NC 2833�
Addres(Aeency ! � Phone No.:
Signature- C< ' - ^� r �� — _ _Date: —(8—c(
AWC -- January 1,1997 2

D). Application and Handling Equipment
Check- the opnroprinre box
Existing, or expanding facility with existing waste application equipment {��TUP or I)
Animal vvasTe application equipment specified in the plan has been either field calibrated or evaluated in
accordance with exlstinP design charts and tables and is able to apply waste as necessary to accommodate the
waste management plan: (existing application equipment can cover the area required by the plan at rates not to
exceed either the specified hydraulic or nutrient loading rates, a schedule for tithing of applications bas been
established; required buffers can be maintained and calibration and adjustment guidance are contained as part of
the plan).
New. expanded, ore istina facility without existing waste application eQuil2ment fors rav
irrigation. (I)
Animal waste application equipment specified in the plan has been designed to apply waste as necessary to
accommodate the waste management plan; (proposed application equipment can cover the area required by the
plan at rates not to exceed either the specified hydraulic or nutrient loading rates; a schedule for tithing of
applications has been established; required buffers can be maintained; calibration and adjustment guidance are
contained as part of the plan).
Cl jSew. expanded, or exisEin-facility%sJthout existi waste application equipment for land
spreading not using spray irrigation_ (NVUP or I)
Animal waste application equipment specified in the plan has been selected to apply waste as necessary to
accommodate the waste management plan; (proposed application equipment can cover the area required by the
plan at rates not to exceed either the specified hydraulic or nutrient loading rates; a schedule for timing of
applications has been established; required buffers can be maintained: calibration and adjustment guidance are
contained as part of the plan).
Name of Technical Specialist (Please Print):
Affiliation:
Address(Aaency)?"
Signature:.
to No.
E) Odor Control, Insect Control, Mortality Management and Emergency Action Plan SD
SI, «'UP, RC or 1)
The waste management plan for this facility includes a Waste Management Odor Control Checkbit, an Insect Control
Checklist, a ?Mortality Management Checklist and an Emergency Action Plan. Sources of both odors and insects
have been evaluated with respect to this site and Best Management Practices to Minimize Odors and Best
Nlanasement Practices to Control Insects have been selected and included in the waste management plan. Both the
Mortality Management Plan and the Emergency Action Plan are complete and can be implemented by this facility.
Name of Technical Specialist (Please Print): Samuel G. Warren, DC
Affiliation: USDA - Natural Resources Conservation Service
Address(Agency):122 Ag. Servics Center, Elizabethtown, NC 28337
Signature:,
C
e No.: 910-862-6936
g 18 � 2- -
F) AN'ritten Notice of New or Expanding Sm-ine Farm
The folio%%ing signature block is only to be used for new or expanding swine farms that begin construe i n after June
21,1996. if the facility was built before June 21, 1996, when was it constructed or last expanded Z
1 (tive) certify that 1 (we) have attempted to contact by certified mail all adjoining property owners and all property owners
who own property located across a public road, street. or highway from this new or expanding swine fans. The notice was in
compliance with the requirements of NCGS 106-805_ A copy of the notice and a list of the property owners notified is
attached.
Fame of Land Owner :
Signature: _ _—
Name of Manager(if different from owner):
Date:
Signature Date:
A11'C -- January 1, 1997 3

III. Certification of Installation
A) Collection, Storage, Treatment Installation
New, expanded or retrofitted facility (SI)
Animal waste storage and treatment structures, such as but not limited to lagoons and ponds, have been installed in
accordance with the approved plan to meet or exceed the minimum standards and specifications.
For existing factliti s without retrofits, no certifccation is necessary.
Name of Technical Specialist (Please Print):
Affiliation:
Address(Agency): Phone No.:
Signature: Date:
B) Land Application Site (WUP)
Check the appropriate box
The cropping system is in place on all land as specified in the animal waste management plan.
O Conditional Approval: all required land as specified in the plan is cleared for planting; the cropping system
as specified in the waste utilization plan has not been established and the owner has committed to establisb the
vegetation as specified in the plan by (monthlday/year); the proposed cover crop is appropriate
for compliance with the wasteutilization plan.
0 Also check this box if appropriate
if the cropping system as specified in the plan can not be established on newly cleared land within 30 days
of this certification, the owner has committed to establish an interim crop for erosion control;
.. 7'
Name of Technical Specialist (Please Print):
Affiliation
Address(Agency)'
Signature:
No.
This following signature block is only to be used when the boa for conditional approval in III. B
above has been checked. J._
I (we) certify that 1 (we) have cornrnitted to establish'the ciopping system as specified in my'(our) w•astc' utilization plan, and
if appropriateid establish the interim crop for erosion control, and will submit t9 DEM a > rification of completion from a
Technical Specialist within 15 calendar days following the date specified in the conditional certification. I (we) realize that
failure to submit this verification is a violation of the waste management plan and will subject me (us) to an enforcement
action from DEM.
Name of Land Owner :
Signature:
Name of Manager(if different from owner):
Signature:
Date:
Date:
AWC -- January 1, 1997 4

C) lkunoff Controls from Exterior Lots ('RC)
Facilitsv -with exterior lots
Methods to minimize the run off of pollutants from lounging and heavy use areas have been installed as specified
in the plan. _
For facilities'"_ithout exterior lots, fro certification is necessary.
Name of Technical Specialist (Please Print):
Affiliation:
Address(Agency): Phone No.-
Si -nature: Date:
D) Application and Handling Equipment Installation («'UP or I)
Check theLgppropriare block
Animal waste application and bandling equipment specified in the plan is on site and ready for use; calibration
and adjustment materials have been provided to the owners and are contained as part of the plan.
O Animal waste application and handling equipment specified in the plan has not bcen installed but the owner
has proposed lcasing or third party application and has provided a signed contract; equipment specified in the
contract agrees with the requirements of the plan; required buffers can be maintained; calibration and
adjustment guidance have been provided to the owners and are contained as pan of the plan.
3 Conditional approval: Animal waste application and handling equipment specified in the plan has been
purchased and will be on site and installed by (month/day/year); there is adequate storage to
hold the waste until the equipment is installed and until the waste can be land applied in accordance with the
cropping system contained in the plan; and calibration and adjustment guidance have been provided to the
owners and arc contained as part of the plan.
Name of Technical Specialist (Please Print):
Affiliation: �5�� - I�ac�ra; r,v,�,es C �;�se►�a,i�r� Sery,cE
Address(AaencN,)a 22 Ay_ Servl,;e Center, Eiizjb#ithto.vn. NC 2 PhoneNo.:��n-
Signature:. - ta�,�_ ,�� . - Date: 13?-13`9
The foliowina signature block is onh. to be used when the box for conditional approval in III D
above has been checked.
I (ire) certify that I (we) have committed to purchase the animal waste application and handling equipment as
specified in my (our) waste management plan and will submit to DEM a verification of deliver), and installation
from a Technical Specialist within 15 calendar days following the date specified in the conditional certification. I
(we) realize that failure to submit this verification is a violation of the waste management plan and will subject me
(us) to an enforcement action from DEM.
Name of Land Owner:
Signature: Date:
Dame of 1lianager(if different from ovmer):
Signature: Date:
E) Odor Control Insect Control and Mortality Management SD SI NA'UP RC or I
Methods to control odors and insects as specified in the Plan have been installed and are operational. The
mortality management system as specified in the Plan has also been installed and is operational.
Name of Technical Specialist (Please Print):
Affiliation: _ . - I . a.., _. _ _ _ I,..... _ ... _ a . J
y Address (AQenc):
Signature-
A«VC -- January 1.1997
hone No.. :.
Date:a_-L8_—_i_7
1:

Please return the completed form to the Division of Water Quality at the following address:
Department of Em-ironment, Health, and Natural Resources
Division Of Water Quality
Water Quality Section, Compliance Group
P.O. Box 29535
Raleigh, NC 27626-0535
Please also remember to submit a copy of this form along with the complete Animal Waste
Management Plan to the local Soil and Water Conservation District Office and to keep a copy in
your files with your Animal Waste management Plan.
NVC -- January 7, 1997

tL�
O O�
NO c
,v a esrs m �"iw c a u�nr o� snrouns °
•r (HIJON NMO1H13BV7173) 9..
SID
le
En
2
7ai
U
41
—71
DI ,

Swine Farm Waste Management Odor Control Checklist
51111-'ce Cuuse IIMPs to h1i lhuice (idol• Silt: Spccific Pracliecs
Farrllstcall • Swille production Vedelalivc or wooded buffers;
11ccomnicndcd best ntanagcmew practices;
Good judgment and common scnst:
Animal body surfaces - flirty manure -covered annuals C7 lary floors
Dinar saufaccs - Wet malmre-covered flours Slotted floors;
Walcrers localed over slolted floors;
Cl Feeders at high end of solid floors;
0 Scrape manure buildup from floors;
M Undcrfloor venlilation for drying
hLlnure culltcliull Ails • 1161c; RI Frequent Inanurc removal by flush, pit recharge,
- Partial microbial decrimposilion or scrape;
fa Underfloor ventilation
VC1101d1nnl C\hilnm (i1115 • Volallle Fall lllilllllellinll e;
Dust Eflicicnt air Illovemcnl
IiulUnr Stir CaLcs - Dust
Washdnwu between groups of auiulals;
Feulluhlilives;
0 Feeder covers;
Feed delivery downspout extenders to feeder
covers
Flush woks - Agilalion of recycled lagoon 177 Flush tank covers;
liquid while lanks are filling Cl EMend fill lines to vicar bnllrnn of lanks wish
at11i-5lpholl vents
l lu ll a11, ys - Agitulion during waslcwatcr 1! Underfloor flush wish uudcrllnor vemilatiun
conveyance
11il lcilial I;c points - Agilalinn orrecycled lagonn f7 Extend rccllllrgt: flocs to near lnluunl ul'I�ils
Iilplid while pill arc filling wilh anti -siphon vents
Lill AMiuos • Agiwlion during sully Lank f_7 Suulp tank cuvcros
filling and dm%vilown
oiii i+lc drain collection - Agilaliuu thlring wastewater C1 Ilox covers
ur jnllctiull hllxes nj� conveyance
Atvlrlc; - Iduvua ber 11, 1996, Page 3

Source Cause BMl's to Minimize Odor Site Spccifte i'raclices
End of drainpipes at • Agitation during wastewater Cl Extend discharge point of pipes underinealll
lagoon conveyance lagoon liquid level
Lib0011 surl:Ices • Volalill: gas calissions; Proper lagoon liquid capaciy;
• Biological mixing; Correct lagoon startup procedures;
Agitation tj}' Minimum surface area-lo-volllulc raiiu;
Minimum agilation whewpunnpiou.,
❑ Mechanical acraliou,
n PfOVCn biological addilivcs
116l;aliun sprinkler • high pressuru agitalion; lrrigale on dry days wilh tilde or no wind;
umccics . WiuJ thifl I1A Minimum recommcuded operating pressure;
4 Pump intake near lagoon liquid surface;
M Pump from second-slage lagoon
51i,1 ��;c I;ink or basill • l'arliul microbial Jccomposilion; C1 114lunnn or mi,llevel loading;
"`rI"e` r 111 • Mixing while: tilling; C7 Tunk covers;
Al;ilaliou when cmplying ❑ Basin surface Inals of solids;
rrrYYY Cl Proven biological additives or oxidants
Sculillu lwl ill surlace • Parlial nlicrubial decomposition; ❑ Ia1lelld drllllp•pc llnnlet5 1111durllcalll ll[IIii(I
Mixing while filling; level;
�Y Abilatioa when emptying ❑ Remove scillcd solids regularly
khmirc, slurry or sludge • Agitation wheel' spreading; C1 Soil injeclion of slurrylsImIges;
sprea,ler uullels�f . Valalilc gas emissions ❑ Wash'residual manure from spreader after use;
r ( Cl Proven biological add ilives or oxidams
lhlcumed mamlre, Volalile gas emissions while ❑ Soil imjeclioln ul'slurrylsludges
slurry or shulgc on field drying ❑ Soil incorporation within �18 llrs.;
5111 l acc I
Spread in 11do m6fornl 1,lyers fur rapid drying;
❑ Proven biological additives or oxidmos
I lc;,d ;Iulul;,ls 0 Carcass decolmposilio n Proper disposition of carcasses
Dead aniu,ui diauls e� . Carcass decomposilion M Complete covering of carcusscs in imrial tits;
fits p" ❑ Proper locslion/colnstruclion of disposul pits
111611 l;Lluls I`r 10, • lmcumplcla cuolbllstiun Cl Secondary slack burners
AMOC - Movenlber 11, 1996, Pagc 4

som-cc CUIISC HKIII's to Rlhtfutt•r.c Odor Site Specific Practices
Slaudirig walcr around • Improper drainage; Grade and landscape such that water drains
facifi�ies Microbial decomposition of way front futilities
organic matter
Mauurc tracked otuo Poorly nwi,dained access roads .anu access road maintenance
jmhli4 roads Irma frrnt
access
Additional Informalian : Available from :
Swim; Munurt: Manal emunl ; 02001IulcIDNIP Packet NCSIJ, Cumay I mansion Ccnlcr
Swine Production Fantl Potential Odor Sources and Remedies ; HIIAC Pact Sheet NCSU - BAF
Swint Production Facility Manure Mattagernent: fit Recllargc - Lagoon Treatment ; r-BAE- 129-88 NCSU - IIAli
Swiuc Produc(iott Facility Mlanurc Management: Underfloor Flusll - Lal;oon'lYcalutcnl ; FIIAE 129-88 NCSIJ - HAI:
Lauumt Design and Management for Livestock Matulre'rrcalmem and Storage ; CIIAF 103-83 NCSIJ - IIAI:
Calibration of Manure and Wastewater Application Ecloipuicnt ; EBAC Fact Sheet NCSIJ - IIAi:
Controlling Odors from Swint Buildings ; f111-33 NCSIJ - Swine Extcusjun
liuviroamcmal Assurance Progrunt ; NPPC Maonaf NC fork Producers Assoc
fltniuns fur h1anal;ing Odor ; a report tom the Swhtc Odor Task >!orcc NCSIJ Agri Com imications
Tluisaace Cnnccnts in Animal Manure Management: Odors aml Flics ; 11ItO107, 1995 Conference Proceedings Florida [;ooperativc Exicnsion
AJrf( ff. - 14ovenihcr 11. 1996. Page 5

Mortality I1-Ianagement Methods
(check which method(s) are being imolerricnted)
-zi Burial three feet beneath the surface of the ground within 24 hours aftc.
knowled!c of the death. The burial must be at least 300 fcct from any :lowin
stream or public body of water.
Rcndering at a rendering plant 11CCnsCd undo. G.S. 106-16S.7
0 Complete incineration
❑ In the case of dead poultry only, placing in a disposal pit of a size and design
approved by the Department of Agnculturc
Anv method which in the professional opinion of the State Vcterinarian would
maize possible the salvage of part of a dead animal's value without endangering
human or animal health. (Written approval of the State Vctc:inariar, must 'oc
attached)
Insect Control Checklist for Animal Operations
—�� Source causc 11MPS 140 Control tnsccts Situ SlIccifi. Practices
Liquid SyStCInS
Flusll Glutcrs Accuniulation ufsolids Flush systcrlt is dcsil;ucd alul UJUXilted
sufiicicutly to rcnlovc acC11111lllatctl solids front
gutters as designed.
Remove. bridl;ii►1; of accunikilatctl solids itl
disc.hart;e
Liit;ouns ;old fits • Crustal Solids Malplaili lat;nonS, SCillilt; baSnis alltl liilS where
1)cst br�.t;diaa is apparent io niiiiilnizc Ott:
crusling of solids to a dehlli of no «tore than 6 -
*- b incites over nior4 tll;ui 30% of surface.
liaccssivc Vc:yLtalivc l)ccuyial; veycttltioll iW—Maiulaili vol;etativc control alou0 hanks ui'
t I(Imll lagoons 41nd other mit)ouotlnients to 1)rLwunt
accumulation of ttecuying vegetative matter
along water's udge on impamitlniClit'S 1)CriI11CILr.

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
I. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3. Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year. Waste may be applied to land that is eroding
at 5 or more tons, but.less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
5. odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
S. Animal waste shall not be applied to saturated soils, during
rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be considered.
Page: 9

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet to
wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly into water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
the site.
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 10

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
18. If animal production at the facility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22. Waste shall be tested within 60 days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when these
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be
maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North
Carolina regulations.
Page: 11

EMERGENCY ACTION PLAN
PHONE NUMBERS
DWQ 910-486-1541
EMERGENCY rLANAG£MENT SYSTEM 911
SWCD 910-862-6936
NRCS 910-862-6936
L
This plan will be implemented in the event that wastes from
your operation are leaking, overflowing, or running off
site. You should not wait until wastes reach surface waters
or leave your property to consider that you have a problem. -
You should make every effort to ensure that this does not
happen. This plan should be posted in an accessible
location for all employees at the facility. The following
are some action stems you should take.
1: Stop the release of wastes. Depending on the
situation, this may or may not be possible. Suggested
responses to some possible problems are listed below.
A. Lagoon overflow --possible solutions are:
a.
Add
soil to berm to increase
elevation of dam.
b.
Pump
wastes to fields at an
acceptable rate.
C.
Stop
all flows to the lagoon
immediately.
d.
Call
a pumping contractor.
e.
Make
sure no surface water is
entering lagoon.
B: Runoff from waste application field -actions
include:
a. immediately stop waste application.
b. Create a temporary diversion to contain waste.
C. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that
caused the runoff.
e. Evaluate the application rates for the fields '
where runoff occurred.
C: Leakage from the waste pipes and sprinklers -action
include:
a. Stop recycle pump.
b. Stop irrigation pump.
C. Close valves to eliminate further discharge.

d. Repair all leaks prior to restarting pumps.
D: Leakage from flush systems, houses, solid
separators -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c. Make sure no siphon occurs.
d. Stop all flows in the house, flush systems, or
solid separators.
e. Repair all leaks prior to restarting pumps.
E: Leakage from base or sidewall of lagoon. often
this is seepage as opposed to flowing leaks -
possible action:
a. Dig a small well or ditch to catch all seepage,
put in a submersible pump, and pump back to
lagoon.
b. If holes are caused by burrowing animals, trap
or remove animals and fill holes and compact_
with a clay type soil.
C. Have a professional evaluate the condition of
the side walls and lagoon bottom as soon as
.possible.
2. Assess the extent of the spill and note any obvious
damages.
a. Did the waste reach any surface waters?
b. Approximately how much was released and for what
duration?
C. Any damage noted, such as employee injury, fish
kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface
waters?
f. Could a future rain event cause the spill to reach
surface waters?
Y g. Are potable water wells in danger (either on or off
of the property)?
h. How much reached surface waters?
3: Contact appropriate agencies.
a. During normal business hours, call your DWQ
(Division of Water Quality) regional office; Phone
910-486-1541• After hours, emergency number: 919-
733-3942. Your phone call should include: your
name, facility, telephone number, the details of

the incident from iten 2 above, the exact location
of the facility, the location or direction of
movement of the spill, %.reather and wind conditions.
The corrective measures that have been under taken,
and the seriousness of the situation.
b. If spill leaves property or enters surface waters,
call local EMS Phone number - 911-.
C. Instruct EMS to contact local Health Department.
d. Contact CES, phone number 910-862-4591, local SWCD
office phone number 910-862--6936, and local 2IRCS
office for advice/technical assistance phone number
.910-862-6936_
4: If none of the above works call 911 or the Sheriff's
Department and explain your problem to theca and ask
that person to contact the proper agencies for you.
S: Contact the contractor of your choice to begin repair
of problem to minimize off --site damage.
a.
b.
c.
Contractors Name:
Contractors Address:
Contractors Phone:
0
6: Contact the technical specialist who certified the
lagoon (NRCS, Consulting Engineer, etc.)
a. ?Mane:
b. Phone:
7: Implement procedures as advised by DWQ and technical
assistance agencies to rectify the damage, repair the
system, and reassess the waste management plan to keep
problems with release of wastes from happening again.
el.ud.ln. a1lW vdlem ��c [Fl.n.dca
r.i� 12,96

IRRIGATION SYSTEM DESIGN PARAMETERS
Landowner/Operator Name:
Address:
Telephone:
TABLE'! - Field Specifications'
County:
Date: `&-06 -� -i
Ficld
Number
Approximate
Maximum
Useable Size
of Fields
(acres)
Soil Type
Slope
{'/,j
Crop(s)
Maximum
Application
Rate +
(inlhr)
Maximum
Application
per Irrigation
Cycle
(inches) Comments
D, -27
SnS " I
I
l
l
'Table to be completed in its entirety by Field Office personnel and forwarded to the irrigation system designer.
'See attached map provided by the Field Office for field location(s).
'Total field acreage minus required buffer areas.
'Refer to N. C. Irrigation Guide, Field Office Technical Guide, Section Il G. Annual application must not exceed the agronomic rates for the soil and crop used.
Irrigation Parameters
October 1995
page-1
USDA•NRCS
North Carolina

ANIMAL WASTE IITILIZAT N PLAN RF C iv E a
`[SECVA
_'. tn�-
����
Producer: V . RAY BEASLEY N���ti��t3Lge Pettnit�n9
Location: 38 TURKEY OAK FARM RD.
WHITE OAK NC 28399
Telephone: [phone]
Type Operation: Existing Wean to Feeder Swine
Number of Animals: 2600.00 pigs
(Design Capacity)
STORAGE STRUCTURE: Anaerobic Waste Treatment Lagoon
APPLICATION METHOD: Irrigation
The waste from your animal facility must be land applied at a
specified rate to prevent pollution of surface water and/or
groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops
in the fields where the waste is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient.
Waste should be analyzed before each application cycle. Annual soil
tests are strongly encouraged so that all plant nutrients can be
balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization
plan in order to maximize the fertilizer value of the waste and to
ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown
and the nutrient content of the waste. Do not apply more
nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration
rates, leaching potentials, cation exchange capacities, and
available water holding capacities.
3. Normally waste shall be applied to land eroding at less than
5 tons per acre per year. Waste may be applied to land
eroding at 5 or more tons per acre annually, but less than
to tons per acre per year providing that adequate filter
strips are established.
4. Do not apply waste on saturated soils, when it is raining, or
when the surface is frozen. Either of these conditions may
result in runoff to surface waters which is not allowed
under DWQ regulations.
Page: 1

ANIMAL WASTE UTILIZATION PLAN
5. Wind conditions should also be considered to avoid drift and
downwind odor problems.
6. To maximize the value of the nutrients for crop production
and to reduce the potential for pollution, the waste should
be applied to a growing crop or applied not more than 30
days prior to planting a crop or forages breaking dormancy.
Injecting the waste or disking will conserve nutrients and
reduce odor problems.
This plan is based on the waste application method shown above. If
you choose to change methods in the future, you need to revise this
plan. Nutrient levels for different application methods are not the
same.
The estimated acres needed to apply the animal waste is based on
typical nutrient content for this type of facility. Acreage
requirements should be based on the waste analysis report from your
waste management facility. In some cases you may want to have plant
analysis made, which could allow additional waste to be applied.
Provisions shall be made for the area receiving waste to be flexible
so as to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for specific
crop production.
This waste utilization plan, if carried out, meets the requirements
for compliance with 15A NCAC 2H .0217 adopted by the Environmental
Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR (gallons, ft3, tons, etc.)
2600 pigs x .40 tons waste/pigs/year = 1040 tons
AMOUNT OF PLANT AVAILABLE NITROGEN (PAN) PRODUCED PER YEAR
2600 pigs x .48 lbs PAN/pigs/year = 1248 lbs. PAN/year
Applying the above amount of waste is a big job. You should plan
time and have appropriate equipment to apply the waste in a timely
manner.
The following acreage will be needed for waste application based on
the crop to be grown, soil type and surface application.
Page: 2

ANIMAL WASTE UTILIZATION PLAN
TABLE l: ACRES OWNED BY PRODUCER
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AW N
PER
ACRES
AW N
PER AC
AC
USED
----
or
------
APPLY
RESID.
APPLIC
METH
N
TIME
10317
1
CE
BH
7
350
0
0.5
175
I
MAR-OCT
10317
1-1
JALL
IG
11
150
10
10.5
125 MAR
10317
2
CE
BH
7
350
0
1
I
I
10.8
1280
MAR-OCT
10317
ALL
SG
1
10—
1-2
1
I
150
10.8
140
OCT-MAR
10317
3
BH
7
350
1
350
JCE
I
11)
MAR-OCT
10317
SG
1
0
1
1-3 JALL
I
150
150
OCT-MAR
10317
4
7
350
0
ICE
JBH
I
�1.2
1420
MAR-OCT
10317
SG
1
0
1-4 JALL
I
150
11.2
160
OCT-MAR
END
I
TOTAL11400
- Indicates that this field is being overseeded (i.e.
interplanted) or winter annuals follow summer annuals.
NOTE: The applicator is cautioned that P and K may be over applied while
meeting the N requirements. In the future, regulations may
require farmers in some parts of North Carolina to have a
nutrient management plan that addresses all nutrients. This
plan only addresses nitrogen.
Page: 3

ANIMAL WASTE UTILIZATION PLAN
TABLE 2: ACRES WITH NOTARIZED AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowners must be attached.)
(Required only if operator does not own adequate land.
See required specification 2.)
TRACT
FIELD
SOIL TYPE & CLASS-
CROP
YIELD
LBS
COMM N
**
* LBS
DETERMINING PHASE
CODE
AN N
PER
ACRES
AW N
PER AC
AC
USED
-----
or
-------
APPLY
RESID.
APPLIC
METH
N
TIME
END
TOTAL10
Indicates that this field is being overseeded (i.e. interplanted) or
winter annuals follow summer annuals.
In interplanted fields (i.e. small grain, etc, interseeded
in bermudagrass), forage must be removed through grazing,
hay and/or silage. Where grazing, plants should be grazed
when they reach a height of six to nine inches. Cattle
should be removed when plants are grazed to a height of four
inches. In fields where small grain, etc, is to be removed
for hay or silage, care should be exercised not to let small
grain to reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too
high and this will definitely interfere with stand of
bermudagrass. This loss of stand will result in reduced
yields and less nitrogen being utilized. Rather than
cutting small grain for hay or silage just before heading as
is the normal situation, you are encouraged to cut the small
grain earlier. You may want to consider harvesting hay or
silage two to three times during the season, depending on
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late
September or early October. Drilling is recommended over
broadcasting. Bermudagrass should be grazed or mowed to a
height of about two inches before drilling for best results.
Page: 4

ANIMAL WASTE UTILIZATION PLAN
** Acreage figures may exceed total acreage in fields due to
overseeding.
* lbs AW N (animal waste nitrogen) equals total required nitrogen
less any commercial nitrogen (COMM N) supplied.
The following legend explains the crop codes used in tables 1 and 2 above:
CROP CODE
CROP
UNITS
PER UNIT
BH
SG
.HYBRID BERMUDAGRASS--HAY
SMALL GRAIN OVERSEEDED
TONS
AC
50
50
TABLE 1
TABLE 2
TOTAL
TOTALS FROM TABLES 1 AND 2
ACRES
LBS AW N USED
3.5
1400
0
0
3.5
1400
* BALANCE
-152
*** This number must be less than or equal to 0 in order to
fully utilize the animal waste N produced.
Page: 5

ANIMAL WASTE UTILIZATION PLAN
i
-a
*** This number must be less than or:equal to 0 in order to fully
utilize the animal waste N produced.
Acres shown in each of the preceding tables are considered to be the
usable acres excluding required buffers, filter strips along ditches,
odd areas unable to be irrigated, and perimeter areas not receiving
full application rates due to equipment limitations. Actual total
acres in the fields listed may, and most likely will be, more than
the acres shown in the tables.
See attached map showing the fields to be used for the utilization of
animal waste.
SLUDGE APPLICATION:
The waste utilization plan must contain provisions for periodic land
application of sludge at agronomic rates. The sludge will be `nutrient
rich and will require precautionary measures to prevent over application
of nutrients or other elements. Your production facility will produce
approximately 197.6 pounds of plant available nitrogen per year in the
sludge.
If you remove the sludge every 5 years, you will have approximately 988
pounds of PAN to utilize. Assuming you apply this PAN to hybrid
bermudagrass hayland at the rate of 300 pounds of nitrogen per acre, you
will need 3.29333333333 acres of land. If you apply the sludge to corn at
the rate of 125 pounds of nitrogen per acre, you will need 7.904 acres
of land. Please be aware that these are only estimates of the PAN and
land needed. Actual requirements could vary by 25% depending on your
sludge waste analysis, soil types, realistic yields, and application
methods.
APPLICATION OF WASTE BY IRRIGATION
The irrigation application rate should not exceed the intake rate of the
soil at the time of irrigation such that runoff or ponding occurs. This
rate is limited by initial soil moisture content, soil structure, soil
texture, water droplet size, and organic solids. The application amount
should not exceed the available water holding capacity of the soil at the
time of irrigation nor should the plant available nitrogen applied exceed
the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan,
it is the responsibility of the producer and irrigation designer to ensure
that an irrigation system is installed to properly irrigate the acres
shown in Tables 1 and 2. Failure to apply the recommended rates and
Page: 6

ANIMAL WASTE UTILIZATION PLAN
E
amounts of nitrogen shown in the tables may make this plan invalid.
The following table is provided as a guide for establishing application
rates and amounts.
Tract
` Field !
Soil Type
I Crop
10317
I 1
CE
I BH
10317
rI 2 I
CE
BH
10317
E
3
CE
BH
10317
4
CE
i BH
Application RatelApplic. Amount
(in/hr) (inches)
0.75 j *0.75
0.75
0.75
0.75
*0.75
4
*0.75
*0.75
* This is the maximum application amount allowed for the soil
assuming the amount of nitrogen allowed for the crop is not over
applied. In many situations, the application amount shown cannot
be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil
conditions.
Your facility is designed for 180.00 days of temporary storage and
the temporary storage must be removed on the average of once every
6.00 months. In no instance should the volume of the waste be stored
in your structure be within the 25 year 24 hour storm storage or one
foot of freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to
ensure that the.spreader equipment is operated properly to apply the
correct rates to the acres shown in Tables 1 and 2. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may
make this plan invalid.
Page: 7

ANIMAL WASTE UTILIZATION PLAN
Call your technical specialist after you receive the waste analysis
report for assistance in determining the amount of waste per acre and
the proper application rate prior to applying the waste.
NARRATIVE OF OPERATION
61-
o Sd� u
a
a
f "l ii�4G' I • "S� / A i7 ram[. S
V
Page: 8

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by
runoff, drift, manmade conveyances, direct application, or
direct discharge during operation or land application. Any
discharge of waste which reaches surface water is prohibited.
2. There must be documentation in the design folder that the
producer either owns or has an agreement for use of adequate.
land on which to properly apply the waste. If the producer does
not own adequate land to properly dispose of waste, he/she shall
provide a copy of an agreement with a landowner who is within a
reasonable proximity, allowing him/her the use of the land for
waste application. It is the responsibility of the owner of the
facility to secure an update of the Waste Utilization Plan when
there is a change in the operation, increase in the number of
animals, method of utilization, or available land.
3.' Animal waste shall be applied to meet, but not exceed, the
nitrogen needs for realistic crop yields based on soil type,
available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict
the rate of application for other nutrients.
4. Animal waste shall be applied to land eroding less than 5 tons
per acre per year.. Waste may be applied to land that is eroding
at 5 or more tons, but less than 10 tons per acre per year
providing grass filter strips are installed where runoff leaves
the field. (See FOTG Standard 393 -Filter Strip)
5. Odors can be reduced by injecting the waste or disking after
waste application. Waste should not be applied when there is
danger of drift from the irrigation field.
6. When animal waste is to be applied on acres subject to
flooding, it will be soil incorporated on conventionally tilled
cropland. When applied to conservation tilled crops or
grassland, the waste may be broadcast provided the application
does not occur during a season prone to flooding. (See "Weather
and Climate in North Carolina" for guidance.)
7. Liquid waste shall be applied at rates not to exceed the soil
infiltration rate such that runoff does not occur offsite or to
surface waters and in a method which does not cause drift from
the site during application. No ponding should occur in order
to control odor or flies.
8. Animal waste shall not be applied to saturated soils, during
rainfall events, Or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such
a manner that the crop is not covered with waste to a depth that
would inhibit growth. The potential for salt damage from animal
waste should also be considered.
Page: 9

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
10. Waste nutrients shall not be applied in fall or winter for
spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to
take up released nutrients. Waste shall not be applied more
than 30 days prior to planting of the crop or forages breaking
dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall
comply with the following: The outer perimeter of the land area
onto which waste is applied from a lagoon that is a component of
a swine farm shall be at least 50 feet from any residential
property boundary and from any perennial stream or river (other
than an irrigation ditch or canal. Animal waste other than
swine waste from facilities sited on or after October 1, 1995),
shall not be applied closer than 25 feet to perennial waters.
(See Standard 393 - Filter Strips).
12. Animal waste shall not be applied closer than 100 feet -to
wells.
13. Animal waste shall not be applied closer than 200 feet of
dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property
and public right-of-ways.
15. Animal waste shall not be discharged into surface waters,
drainageways, or wetlands by a discharge or by over -spraying.
Animal waste may be applied to prior converted cropland provided
they have been approved as a land application site by a
"technical specialist". Animal waste shall not be applied on
grassed waterways that discharges directly into water courses,
and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from
the site.
16. Domestic and industrial waste from washdown facilities,
showers, toilets, sinks, etc., shall not be discharged into the
animal waste management system.
17. A protective cover of appropriate vegetation will be
established on all disturbed areas (lagoon embankments, berms,
pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and
other woody species, etc., are limited to areas where considered
appropriate. Lagoon areas should be kept mowed and accessible.
Berms and structures should be inspected regularly for evidence
of erosion, leakage or discharge.
Page: 10

WASTE UTILIZATION PLAN
REQUIRED SPECIFICATIONS
18. If animal production at the fapility is to be suspended or
terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should
be inspected on a regular basis to prevent breakdowns, leaks,
and spills. A regular maintenance checklist should be kept on
site.
20. Animal waste can be used in a rotation that includes vegetables
and other crops for direct human consumption. However, if
animal waste is used on crops for direct human consumption it
should only be applied preplant with no further applications of
animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and
bottom elevations of the temporary storage (pumping volume) of
all waste treatment lagoons. Pumping shall be managed'to
maintain the liquid level between the markers. A marker will
be required to mark the maximum storage volume for waste
storage ponds.
22. Waste shall be tested within 50 days of utilization and soil
shall be tested at least annually at crop sites where waste
products are applied. Nitrogen shall be the rate - determining
element. Zinc and copper levels in the soils shall be
monitored and alternative crop sites shall be used when these
metals approach excessive levels. pH shall be adjusted for
optimum crop production and maintained. Soil and waste
analysis records shall be kept for five years. Poultry dry
waste application records shall be maintained for three (3)
years. Waste application records for all other waste shall be
maintained for five (5) years.
23. Dead animals will be disposed of in a manner that meets North
Carolina regulations.
Page: .11

ANIMAL WASTE UTILIZATION PLAN
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm:YORICK NURSERY
owner/Manager Agreement
I (we) understand and will follow and implement the specifications
and the operation and maintenance procedures established in the
approved animal waste utilization plan for the farm named above. I
(we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the
North Carolina Division of Water Quality (NCDWQ) before the new
animals are stocked. I (we) also understand that there must be no
discharge of animal waste from this system to surface waters of the
state from a storm event less severe than the 25-year, 24--hour
storm. The approved plan will be filed on -site at the farm office
and at the office of the local Soil and Water Conservation District
and will be available for review by NCDWQ upon request.
Name of Facility Owner: V. RAY BEASLEY
(Please print) 1 `
Signature: v + \ Date:` �Q
Name of Manager(If different from owner):
Signature: _ Date:
Name of Person Preparing Plan: (Please print)Samuel G. Warren
Affiliation:USDA- MRCS Phone No. 910-862-6936
Address (Agency): 122 Ag. Service Ctr.
Elizabethtown NC 28337
Signature: �,�Gn.--� ��. Date: P.-16-
Page: 12

PROJECT
XSTE
=WME=WAS�M DESIGN
Table of Contents
RECEIVED
WkiER �� I�, ;�` SEC' 10t4
Non-DischaT. a Permitting
Page Page
Cover letter with volume estimates
!
of L
Location and Topographic Map
y
of
Plan Map
of
of
Soils Map
5
of
Soils borings log
Waste Utilization Plan (pg.l)
of
Waste Utilization Plan (pg.2)
7
of
of
Design Notes
Operation and Maintenance Plan
_L
__T_
of
Design Calculations (pg.l)
D
of
Design Calculations (pg.2)
of
of
Design Calculations (pg.3)
1y
Dike Fill Calculations
of
Of
Excavation Quantity Calculations
°f
Of
,tlmiveateek Waste
of
Landowner/SCS Responsibilities
of
of
Grid and Overall Plan View
of
Typical Plan Cross -Section
of
Excavation cross -sections
/6
of
Construction specifications
_LZ
of
Seeding specifications_
of
of
Other
of f
Other
of
Other
--
•41- Copl e-s JqR

Urded States Solt
DepertrTennen t of Conservation 122 Agriculture Services Center
Depar Service Elizabethtown, NC 28337
Agric0( 919 ) 862-6936
OPERATOR: 1�
This is your animal waste system design and specifications. Please
review it carefully. Retain this plan for your use and records. It
is strongly recommended that you, your contractor and Soil
Conservation Service personnel are in agreement as to how the waste
lagoon is to be constructed. SCS personnel will meet with all
concerned parties and walk over the site to explain all flags and
markings. If further layout is required by the contractor than is
provided, feel free to contact us. It is important that everyone
understand what is expected so that final construction/seeding meets
plans and specifications for certification.
As you requested, this design contains no added volume for sludge
(solids) that will accumulate over time . Sludge will be removed as
needed, however to maintain the efficient operation of the system.
The lagoon embankment has a HAZARD CLASS "A" design. Sudden failure of
the embankment will not endanger life or damage public transportation
facilities. If failure should occur, lagoon would drain into
wo oto A-dr,4 , which is /oo estimated feet
from lagoon, which in turn would eventually drain into
Cs�ce k
The actual amount of material required for pads and dam may vary from
the estimates. The design will attempt to balance cuts and fills as
close as possible. If additional material is required after
construction' is complete on the lagoon, the contractor and owner will
negotiate on the price and location of borrow areas. Any movement of
topsoil is in excess of amounts specified below.
NOTE: Design Capacity -
(excludes 1' freeboard)
Excavation Estimate
Embankment Estimate =
Estimation of Pad Fill
A19: Cut -Fill Ratio
JOB CLASS DATE y o 2—
kyl-5. QOR,eo w
6174:;el 0w yoe- B fit/
Designed by:
Design Approval: �� � ^c. Date 7 /° 4Z—
rr,ew scon.ervarion Service
`i h an agency of nre
/ 09POnment of Agmuft►e

i
o CD o in
r' 4 3N H ssrS
.ON NMOLi 36VZ173) I �-�---��--- �- -
La
173
cr
uk—
. r �,.�\-_' � �` \ * ���_•� ice- _ f��.- �7T��'"NlC/.�'/ 17 - J .1 .'� w.71-
ram,: � "J -�.� 1� `L -- \�• .,/ I. / ..� � �_..�� "�./ /! •
J N� - ! 1.. ♦ G -

(;' _ � i�• +��''e.. • �e'.Ty •., y`•Z' fit•
t�',�. �;�i '.t ~'S� �yr '! s'+: s �., .��:rTi-�Y��.�i+. t..Ts 'F .�'�:+1.''..! :• i.,�?:�'` _�"ti 7-*'� �'y rv:y,•,:_, �: sti
'd3Y+r f�y{S.S��.. .�+•'. Y. ,}-: C- r I�?S\S.}i'.f. :y�5:. •r',�� f,� � ii__c/ ti\; ys.�!'�J ' S5.•.:a'�.. �i-� i�t� �'.y� rf'K•�
Z "f`=_,j a. 3` •E.. Y s �y�i4.. th�i f},- -.y ��,=w.J.4 ������.
Iy Vr
f
S Y • 9 . r ;tip• - ��rC �,. __
♦ � L S ♦ � �, 1 •� - - 1 � tilt._". +;:�+. �:. [1.1•T/ .� �, r -.. � Jx �A.�.. !. 1 t
�•! `k 'i^'' � �1 S _ � t .. !tf• r.r �'� ��L1f���,,y•� l 1�: r Lai I" �
�,t_r�,•'.7a {ff�, i` _ Lrr\; - -i '4'•�;;, fT-xv— �-J ''dr :i' �i-�: v'7r` `t,., „�.l�y} •+xr:t-='.�`'��p •i :e YYT ..
^�•� ,�� .. � � ', � `�� w x �. `., �i+ice �a � 5r�t,
% ii
\ ..\w- ..-�.. T. -. t`. `}.y y`�'•r .,� H4TTS1 J Y" f
41
Ll
., �i•i rye. .s f lr ."'} (i.. � f
'_� "E ♦.�.jryw�yl� yam. �� ����.•r'r�� E,=E.
'� •; C.�=��hJ,-�-.. ?.�^'+.� trJ +'.�5-!' •��y!• s' K :t,y•-tr! •a��y�`'�"' �.� �ti �. ,. �
1 • • • '

SC.S-CPA-01.5 U. 5. OEPARTMENT OF ACRICULT URti
12-85 50U. CONSERVATION SERVIC: F
SOIL NIAP
Owner Operator
County Slate
r as Soil survey sheet (s) or code nos. Aproximate scale.
Prepared by U. S. Department of Agriculture, Soil Conservation Service cooperating
With Conservation District
;f LaB
?
Cc
I an
LaB
LaB LaEl
Ca LeA C
C
ta
W­
oc
,
P_
_C
47 N C
Ce
c W
adBO
PUT- Pt
7r
Pt
r1z -L CC
Wrl
.7
V LW
\j
A I
141 At
-La-4 N
A jG
74, _...4 tvf
Aal
, 1P
j-
A.
C
p7,
T
j
6A

• SCS-QNG-53a - U. S. 0£PARTMENI W AUHIIUL I UNL
Rey. 5-70 SOIL CONSERVATION SERVICE
SOIL INVESTIGATION TO DETERMINE SUITABILITY OF PROPOSED POND SITE
FARMER'S NAME. _ ,?t -_j�t Z DISTRICT
COUNTY sic �loi'
S. C. S. PHOTO SHEET NO. t? WORK UNIT
WATERSHEI. AREA MEASUREMENTS
CROPLAND ACRES PASTURE ACRES
WOODLAND ACRES TOTAL ACRES POND CLASS WORK UNIT CONSERVATIONIST
SKETCH OF PROPOSED POND SHOWING WHERE BORINGS WERE MADE (Approx. scale I"= feet)
relvence paint -+n cmtrr line of dam and Identify on sketch.
QO
I
r
rym
Q '4C
•
{
i
I
S
It
/
.tom
-
}
r_ate
SHOW
DEPT�I
SCAJ,E
BORING.tr i_ BER AND PROFILE 0�';�j'/
Make and list dam -silt and Spillway borings first • thm pon d borrow i! parate with vernYal red line.
(Continued on back where necessary) Show water table devotions an dorn•sile borings.
i
II'
+
6
is
12
13
14
15
16
17
—
18
19
20
21
22
23
- I
P
$P
j��
fir^
sty,
sc
�c
J-1
r- z-.
4
s c'
s
s
s—
--
-
SP
,f
5 P
s�
_
sc
r��
sc
rn11
3- q
5 P
''.-17
5f
s p
SR
sQ
-
P
d1.
S ('
S P
A V,
5
CA
r-
BORINGS MADE BY G+/�9�RciJ SIGNATURE & TITI `{� ��

TYPES OF MATERIAL ENCOUNTERED IN 13011RINGS
(Use one of systems below)
UNIFIED CLASSIFICATION
USDA CLASSIFICATION
GW -Well graded gravels; gravel, sand mix
g- gravel
GP -Poorly graded gravels
s - sand
GM - Silty gravels; gravel -sand -silt mix
vfs -very fine sand
GC -Clayey gravels; gravel -sand -clay mix
sl - sandy loam
SW -Well graded sands; sand -gravel mix
fsl - fine sandy loam
SP - Poorly graded sands
I - loam
SM -Silty sand
gl - gravelly loam
SC -Clayey sands; sand -clay mixtures
si-silt
ML - Silts; silty, v. fine sands; sandy orclavey silt
sil -silt loam,
CL -CI?ys of low to medium plasticity
cl-clay loam
CH -Inorganic clays of high plasticity
sicl- silty clay loam
Mll -Elastic silts
scl -sandy clay loam
OL-Organic silts and silty clays, low plasticity
sir --silty clay
OH -Organic clays, medium to high plasticity
c - clay
1. Suitable material for embnnicmeut i9 available [E
Yea _] No (Indicate mhe.r [.eared on rh. sketch on
rwpwrm slda)
REMARKS:
2. Explain hararde requirirg. special attention in design 0s­-.rr sn-/no-roaA etc-)
CFNERAL REMARKS: -kk l - Ge a cJZL- t 4� t t /l, Ni7eA
�� Iti[2o n3 fir# 'Z — L' •� e R rv. a. k _Sc
32 w 34 :+5 F 37 3!i T311;I a01 417,421 4�-1-t V45V461 47 1148 49 115{t 51

�''e - ^ � -- - R. si r�P ,=e f �, �i � ;i A,rls=
Cl w r r arrt . rr a , �. � , �� _ u rt t f : L- f d
M a. 1 A."-- rj t- e G c-. 1]
Tyre r_i= pr'oduct ! Or€ uri ! t - -- µ;=AN -FLED
Tyre f wzi to fac I I I t'j --- -.Anaer-'t, ! r La or,
Ycour- an ima! t.,?ste rtnarra'-jer:rerit fac ! I i ty rta= been +jec i'gri--d +:•r- a
JIYen Stet-a'-e capacit;J. When t1€e b:3ste r- eaCheG tr:E esrr:ei�
I eve I , I t rill _!s.t t'e I ar,+j at.'d ar a Sr'e'c I f i cm t-ate tC r:t
_,I Iut:!or, of surface and/iir- 93-our:j '.: ter-. TriG r+Iart` nutr-!errt5
I n the F,n i rill- ? waste C.r€:.0 i ,j bE, u=- _ t+ ,.r'I'uc e tl'ie am.-:'Iur.t
CC1TnI'f)eI-C i a! fer--t i I i zer- r-equi r e,j for tr€e c.'',„'F'c C,ri the f I P-
I c
- -
Iwrier-e the waste I tC, t,e an r r-i i n,- . T r, I c re ut S I I mat I
-Ices ri l tr- „�C-rl =_s the I ITit1 t i n_ rIL'-r ! erlt G'�ac_.te =r:"1-I, ,� be
aria lyzed t+eTclt-e each aC+r+1 icatlori c`,'C!e and arsnuaI I to=-t=
ar'e rnciilw— ed s: that a1 I r' I artt r: U t'I I er:ts C LR bE r, I .ar'ICe f`c't-
r'ea I ! Si. ! C Y i e s f tree c--or, tC. c,a �r C,W!"; .
SE`. ial tC_t_t' ar" eIrrlr_ t n - I Irnr+Iemell', ri � l+�rrltP
rrn r' I art I ri _,r-diet- rf! {'e!-t i ! ' `�. r1 ; Il_ _ !'
the ..atte and t, ensut-= that i t i = ar r, I i e,j i ri an
envIr Vrirl€eritaI Iy safe rnar-tn• - -. A s arr'i i ''Jac re Cased C';-: f:E'
needs C'f''f'rle Ct-or, tr. t'e q i!14n ar:I'- the- nutr- I `'rlt cor:tC- rit r f tr,e
':Jarste D riot ar'r1 ! j rr'!i';-e n t-o'jen than the Cr-„r' Can ut 3 . . Zt'.
�' I j ; ;r r_ c• at _ I rT,r, ,rs-tarit a t t r;e.y tla: e d i f�f�er-cr:t i rif I ! tr-at I C,rl
r' to t: e s: n c1 I E' a C I": ! r, 'l r, i , t E rt `- i a a
I a n d e r- _'-1 ! r, g c.'r, '-i r E-= t e t- t h ?. Fr Er t o r: S D E f W r- r- e i P I' va t- D 1,
rl o t
3Frrri'l !='I^.c. r_''3 3tlrf art'- -- Ic r: I2_r€, 'r:=rtit f�=_
f r Ci e is E I T' h S.' r- f t h e c C _' n ,y I t I n c rn =Y r E. S u I t ( r: t-'- rl of 'f
Sur"face 'datet W . I.xi i rsrj £ :rri,_I i t . _'rsc c.1'ii,u I �! - 1 E': tre c'_ rS= rjet-t',_ ti,
a ;,Ci i ,j 'jt-- 7 t ri,j dri':Jr;:J I niI _ j rr rrr rr1_ I ertSS Ti, rflc I rfl I �= trlF rt I iIF•
i r% i, i t €-i - ,j r[ r, a r ,-i - r- + - t r - i, r i- 1
{' rl u t r e I T !' C S _ r r' : '_' _ .S t I_ r, I t ,_, e j u C `,.:' I e !_ t o 1 �.
r,r,illltii,n, ,the aSte cI1_rtu!ij rr✓ ea r, t' - '?rr irl- -. rr jr
r
riot rii_r trlarl _C-) da _ r,r- _rr_ t_ r'!antirl'-. In._iectirsttae a=te
Cir '7 i 5F': l nc; ',:'! ! ! c:,ns9t- v e riutt ! ent- - an'-S }-edur--£ _ d':', ` rat"CrF, I e-tns .
The aC Erc:. nPE'i-IE; r, tire' arl I itla 1 - t.@ I = L'asE _ f: �"r+ 1 Ca I
nutr- i er!t rig_' 'rt f;,r- tf': i _ +y�„ f'aC i I i t;'. ACr Ea'
r equl r- erl!a!-i t,= rn ay bE, rn ,r e = I Es �'C. c''j ir: trl: atc. aria c
i .
t I- Fiiir-t F r.. j:fi yCtUt" ;taste f's=Lrt S rilr=rtt PaC I 1 t f .
l r1e 'a _ t rl f y,_ ut- wa=_ to Tn r,ar,, r; - f a i 1 i t`, i - t' a -e "n t-._
'in,.
Arric'unt L`, ._ rt. i.'r-:,dacer- Ye-
.
a i c . , 7 . 4 t _ r, c :J �. s t c rl I rrl __ ! i r = } f 1' t -
! _

Al Lr r: {_ ALL I I .-o _+ _, I N i t r-e' rer, I' jar _ ri Fe Yt
C -J I_S n 1 rr w rl . rn ? , '� r = r r-
A r-r r, 1 y! r: Q �I e 2. V e a f: s U ♦-I t :+ f a t e I M a 1_+ i .� ,_! C, , `{ r, L: i t C+ I�
rr ! aft t I niE' �L. n :Ia-VE? ar+r'r:+r+t- i ate e rgLi I r+r%Sr,t t C. F_r,rr I y tr:E- ,hiac rE I rf
a t i rr: e I mariner . r' 11 r- f a c i l i t y i s d e s i +a rl e ,= f c, r ay S {
St:+t-ale- :!'�� !t w i i reed v, [ra rurl,r.e,j e;,Gr-�;
rF: C+ rs t h S .
Tract FieE,J w n i l C:r ; Yield ! tr N Acr-es Lt+s. fd hl c, ntJ-I t:,
Nc, 1'+lrr, Type C:i-irie Fe A . Llse Arrr 4y
A:va i I ab l e Nitrogen tr gen 1
SLlrr+ l u.s r]r- Ele l i c i t - F.
C:r _,r c+er g=: 1=L: r E E �Ir 1rlr a[:r_.r rti--r=S'r f 1-Rar,rrll�+jz
r,tr-+:+I r; a z e d Lerrr:udla; r_.= avIar,+j Derrmuda
Liv.. n [nIra-2 r_ k �'{san-+►s �r�G_� -/ka2�
h-[�Ik�AS,`""�----�i�-}c�-�__����.�c�i=�+.(�___r�_� c's..._._fiCc�----`'�.�J_./_9�--.1�_I_✓..��r.-eL= ��
arld Water - C:,:. r: E., e r vat I r7rr D i S':r I i=t CI f f i cF cf tE
t'E'ct l ve WaSt= aria E `!S l w; , -er, :,r-t t:r -, tL i r, tiie arfi?+urlt � � Y" a c r o tC
aprr I ;' r:r= tf�e i r r } ,gat ! .,r, a t I ,_,r., t..at.e r,r I rrr * _+ r+ I ] rl';
wa te.
F• r- � r, a r- i ,-i r. . � • � FC�r !O � �C �lI 2-
l Narlie T i t l e- Late
r;cul -r-E,i
t.:, rl ,-I r: r: , Y, .- t :r L. -1' I E'

Animal waste lagoons are designed with permanent storage
(waste treatment volume) and temporary storage.
The designed 6 month temporary storage is an estimated
volume based on: 1) waste from animals; 2) excess rainfall
after evaporation; and 3) the largest 24 hour (one day)
rainfall that occurs on the average of once every 25 years.
The volume of waste generated from a given number of animals
will be fairly constant throughout the year and from year to
year. The excess rainfall will vary greatly during the year
and from year to year. This estimate is based on 7 inches
of excess rainfall which is equal to or exceeds the highest
6 months excess in a year., The average annual excess
rainfall is approximately 8 inches. Therefore, an average
of 8 inches of excess rainfall will need to be pumped each
year. The 25 year rainfall will not be a factor to consider
in an annual pumping cycle, but this storage volume must
always be available. A maximum elevation is determined in
each design to begin pumping and this is usually the outlet
invert of pipe from building(s). If the outlet pipe is not
installed on the elevation to begin pumping, a permanent
marker must be installed on this elevation to indicate when
pumping should begin. After -initial filling of lagoon, a
minimum 6 feet depth must be maintained for anerobic
treatment of waste. An elevation must be established to
stop pumping to maintain the minimum treatment depth.
Pumping can be started or stopped anytime between these two
elevations for operating convenience so long as site
conditions permit (conditions are weather, soil, crop, and
equipment to apply waste to prevent runoff or leaching).
For this lagoon the maximum elevation to begin pumping is
_57,_L feet and the minimum elevation to pump to is feet.
The design temporary storage, less 25 year storm, is 3Z 31jr
cubic feet or ;-Y3_yZ-ga I I ons. As stated before, this volume
will vary considerably from year to year.
This lagoon is designed to flush buildings with recycled
lagoon liquid, and fresh water should not be used for
flushing after initial filling.

OPERAT 1 CAN AND MAINTENANCE PLAN
--------
This lagoon is designed for waste treatment '.:Ith minimum odor
contras l . The time required for the planned f i u i d level to be
reached may Vary due to si l tend i t i ons , f l u5hs i ng operations, and
the amount of fresh water added to the systere.
Land application of 'Taste '.Dater" is recognized as an acceptable
method of disposal. Methods of app I i c at i on i nc I ude s l i d set,
center Pivot, gusts, any traveling gun irrigation. Cure should be
taken when applying waste to prevent runoff from the field or damage
to crops.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre -
charged to 11Z its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Sol i ds should be
covered with effluent at ail times. -
2. The attached ::paste utilization plan sha l I be fo I I owed. This
plan recommends sampling and testing of waste ( see Attachment S)
before land apr l i c at i on.
Begin pump -out of the lagoon when fluid level reaches eleva-
t i can SSIA - as marked by -permanent markers . Stop pump --out when
the f l u i d I eve l reaches e I evat i or, 55.S 54- or before f l u i d depth i s
less than 6 feet deep (this prevents the loss of favorable
bacteria) .
4. The recommenced mam imum amount to apply per i rr- i gat i on is
one (1) inch and the recommended maximum app l i cation rate is 0.4
Inch per hour.
F. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be Bert. i l i aed as needed
to maintain a vigorous stand.
6. Repair- any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
outlets.
2. The Clean Water Act of 1977 pr-oh i b i is the discharge of
pollutants into waters of the United Mates. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.

Qerator:Ray Beasely County: BLA.DEN Date:
Distance to. nearest residence (other than owner): 7500.0 feet
i . STEADY STATE LIVE WEIGHT
0 sows
(farrow to
finish)
..
1417
lbs. -
0
lbs
0 sows.
(farrow to
feeder)
..
522
lbs. -
0
lbs
0 head
(finishing
only)
x
135
lbs. -
0
lbs.
0 sews
(farrow to
wean)
N
431
Its. =
0
lb_
2600 head
(wean to feeder)
x
30
lbs. =
78000
lbs
TOTAL STEADY STATE LIVE WEIGHT (SSLW) = 75000lbs
. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 72000 lbs. SSLW x Treatment VoIume(CF)/Ib. SSLW
Treatment Volume (CF) / I b . SSLN= 1 CF/ I b . SSLWI
Volume = 78000 cubic feet
_ . STORAGE VOLUME FOR SLUDGE ACCUMULATION
Volume = 0.0 cubic feet
4. TOTAL DESIGN VOLUME
Inside top length 175.0 feet ; Inside top width 130.0 feat
Top of dike at elevation 59.0 feet
Freeboard 1.0 feet ; Side slopes - 0 : 1 (Inside lagoon)
Total design lagoon l i yu i d I eve I at elevation 58.0 feet
Bottom of lagoon elevation 4?.0 feet
Seasonal high water table elevation 48.0 feet
Total design volume using pr i smo i pia I formula
SS/END1 SS/END2 SS/SIDE1 S'S/SIDE"Z LENGTH WIDTH DEPTH
...ci = .0 3.0 = .0 169.0 1Z4. 0 9.0
AREA OF TOP
LENGTH * WIDTH =
AREA OF BOTTOM
LENGTH * WIDTH =
115.0 70. 0
AREA OF MIDSECTION
LENGTH * WIDTH * 4
142.0 9710
Z0956.0 (AREA OF TOP)
8050.0 (AREA OF BOTTOM)
)
55096.0 ( AREA OF MIDSECTION * 4 )
CU. FT. = CAREA TOP -+ (4*AREA MIDSECTION) + AREA BOTTOM]
VOLUME OF LAGOON AT TOI AL DESIGN LIQUID LEVEL =
?� DEPTH/6
1.
126153 CU . F T .
In

5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
175.0 120.0 22750.0 square feet
BU i l d i ngs (roof and i of water )
Length * Width =
0.0 0.0 0.0 square feet
TOTAL D.A ZZ750.0 square feet
Design temporary storage period to be 180 days.
FA. Volume of waste produced
Approximate daily production of manure in CF/LB S+SLW 0.Q0136
Volume = 7;=:t100 Lbs . SSLW * C:F of Waste/Lb./Day 180 days
Volume = 1 048 cubic feet
5B. Vo l ume of wash water
This is the amount of fresh water- used for washing floors or volume
of fresh water- used for a flush system. Flush systems that recircuIat
the lagoon water are accounted for in 5A.
Vo l ume _ 0.0 gallons/day 190 days storage/7.48 gallons
per C:F
volume = 0.0 cubic feet
5C. Volume of ra i nfa I I in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount
180 days excess ra i nfal I = 7.0 inches
Volume = 7.0 in * DA / 12 inches per foot
Volume = 13270.8 cubic feet
Ix

5D. V I urne oaf year- - 2-4 r,-.�ur- storm
VC, I urne = 7.4.E i aches / 12' i r,ches �,er- fcoc,t DA
Volume = 1 7r_r.._: cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A. 1'Ft C4S, cubic feet
5I::. O cubic feet
S-C. 1=.271 tunic feet
5D. 1:=:�71 cut, i c feet
TOTAL 4F590 cub i s f e e t
6. SUMMARY
Total required volume 1'2:--�,55: C) cuts i c feet
Total design volume avail. 12615-3 cubic feet
Min. req. treatment volume ro l us sludge accumulation 7,8,000 cubic f
At elev. 55.5 feet ; V lume is 7906'.1) cubic feet (end purnpir,3)
Total ,design vo l urne less ''5,yr-- '4hr- stoma i s 112 cub i c feet
At elev. 57.3 feet ; Volume is 111','Io cut,ic feet (star-t rurr�r-
Seasonal h i Sh water- table e ! evat i can 4:=:.0 feet
7. DESIGNED DY: .s,�.��u/.�,��,� APPROVED BY;��y_
DATE: "/ �/9 2- DATE:
NOTE., : SEE ATTACHED WIASTE LET I L I .AT I FIN FLAN
11

AGF1,. rC'U: TI.) .__ Pd -E,.j i -
_ i'1 C:,;f: rr:ati _r: e'er i =e F'ev-
r :i=l!' i1PL ITAT I CIN SHEET
NAME:
SETTLED TOP L)11.-"E ELEVATION. F 1. o
TYPE EARTHWI+RF:'.:
_:._ Dike
_=:1- SS
_ 10'-Tap:
--- E,cca . ---
Fad
STATION
AVE.
FILL
END AREA
SLIM OF
DISTANCE
DC1uPLE
GRC' UN1D
HEIGHT
(Sq. Ft.)
END AREAS
(feet)
VOLUME
140
50.
_ . _
_ 2 1_1 . _ .
((i'; I , ',J'-J
1 I=)
64049
Z451
49.9
9.1
- - . . 4,-
l= 59. 75
92-*74
.fir
FI1,F
=
_C 1 .75
r_,ZZ.f_17
-'!,
2177
65C—
511 . 9
= . 1
77 . =_
45 1 . 9
1051
4;D` JQ
1. D--ub l e V++ I ume of Fill
C:u.
Ft .
�. VoIurr,_ ,f Fi 11 ( I ir,e 1/-_7) =
72" ::=f.7
Cu.
Yd-
_. AI I_�war,ce f.r Settlerr:er,t(1.�=);�:) =
7":=:.Q
Cu.
Yd.
4. T}ita I Cubic Yards (� + :_) _
7'f5-7
Cu.
Yd .
Computed by: �_!.( ,ew ..)
-------------------------------------
Bate- tiZ/U7/;=:4
Checked by: ---------------------------------------
/it

i l t_'r'.':,;
E.AF:TH!};I�IF;r`: G1_11�1i'� ETA I I C1r•! S��EET
NAME:
ADDRESS. —---------•-
-F YPE EA.c THWCIM.': —
— — U I If. e _----S S ---Top
' —)(— Er':
t a v . 9.' / 8S" :
--- Fad
STAT r 1--lN
FILL
END AREA
SUrl F1F
DISTANCE
D13 U[-:? E
----------------------------------------------------------------------
HEIGHT Sq . Ft.
ENT) AREAS
feet
VOLUME
7 5
c:)
201
F
1 ()+.-)ff.
150
_':�
�';�� y
7C)
-:4:=:CsC)
205
Q
f]
0
o
i)
G
Q
i)
it
0
C)
C)
C)
i)
C)
0
C)
C)
0
Cl
r)
C)
C)
C)
C)
i)
is
i)
C)
C)
0
I)
it
0
i)
0
0
0
it
()
0
f)
i 7
i)
i)
i)
i)
0
I)
C)
{ i
0
f ?
[)
0
til
0
C)
0
c f
C)
-------------------------------------
r_.4Z05
1. Double
Vo l erne
of F i 1 1
1C.)5, Cu.
Ft.
L. V�-lurne
-.f Fill
Hine ine 1/27-7) =
11-=o.i) Cu.
Y.j.
_ . Al 1 �.wartce
f 0t- sett
I ernent (10%) =
C:u.
Yd
4. Total
Cubic Yards
(4 + :T,) —
1 C u .
Y d . 1we Lu DES
! � O !/CACc�
"Al /go #0-».
Computed F
by. _J�- _ ftfRc✓—__---------------
Date:
O'Zlu7/c:4
C. h e c 1 e d
by :———————————---
—————————— — — —
— — —
It

LANDOWNER - SOIL CONSERVATION SERVICE RESPONSIBILITIES
Date:
Operator:
This is to review the responsibilities of the Soil
Conservation Service and operators in planning, design,
construction, and operations and maintenance of livestock
waste management systems.
SCS RESPONSIBILITIES:
1. Investigate site or sites with owner to evaluate
location, soils, area needed to receive effluent, etc.,
2. Survey and design system to meet SCS and State guides.
3. Review design with operator.
4. Layout for construction as needed.
5. Construction check and certification.
6. Follow-up to assure operation and maintenance plan
being followed.
OWNER/OPERATOR RESPONSIBILITIES: .
1. Locate or agree to location of operation.
2. Review and concur in design before construction
begins, including location of land and area/crops
needed to receive effluent.
3. Assure that practice(s) is/are constructed as
designed.
4. Maintain and operate system to meet State standards,
including pumping all excess effluent on crops and/or
pasture that will utilize nutrients in effluent per
enclosed plan. Effluent should be applied at rate and
amount to prevent runoff or leaching.
5. Construct and operate system so as to comply with local,
state and federal regulations.
WASTE MANAGEMENT SYSTEMS THAT ARE NOT OPERATED AND
MAINTAINED PROPERLY MAY BE IN VIOLATION OF STATE AND FEDERAL
REGULATIONS.
Some deficiencies in construction and operation that have
occurred and, in some instances, caused complaints, are.
1. Areas around buildings and lagoons not vegetated.
2. Vegetation not maintained by mowing and fertilizing.
3. Waste flowing over lagoon banks.
4. Waste from lagoon flowing through open ditches or pipes
into ditches, streams, ponds, etc.
Should any of these problems occur► contact our office
immediately.

� .�v
Q1 vari7
J• I
N
a1-
-orb-)CA-
r
Ts
[
.
Pp-
Z'Q5
L
pA#'i
•
1
�'0 Pot
oil
a

E Q
I
�
V
04 �r
?
L
7
L 7
,T tr
4
l
U A
t
2
,o
`4
V
SL

r-- -. _ �A _ _I.._ I !. f`I I a'. i :I- - i I_i INA'15- T __ Tf f_Arrl�:.iV' !_A{;i=11 iNS
AI I be r _ _ _ �r Grr. tr:_ c •rt5tr-uct i .rt ar-ec
+ef+arE ?rl"� t ;CaVCt i nL "L f I I 4 i s star te'� St+!r.^.p 5 4J I i C'£ Y'errl!VE=�
I thi ! r: Lr1E ar',?a qF th;£ Fc+urt,�at' _ f th:c =rfi� ar!�-:riierl r 3r:'� t 1 I ! 3! acc
arl. e:.=avated areas. A 1 1 E- 'ir.Ir e and r-oot5 e::ceed i rtg r,rse l 1 )
I ri c h ! y i EL nI e t e Y tl el 1 I h' L' L e ri I'-. V e ,y t'- a rn ! rt I rfl a ri7 r+ hl _+ f +_+ r1 e{
f +-t. Sat 15f'act . r y d i rf,C'_ i t I,?r: '.JI I I t'e made +f z�,.I I-Ic-brI S. The
f!ii-
iridL _ !!.ri area Sr,a i I b i r-cl MF:eL th --.r':'L'•aht I'j' t,ea'"r-` r' 1 aCern3Erit i,f
embar:::f::_r!t inater i a I I_a; c,:,r, w : to rid ad =_ i to i f rteeed) t,_ bc-
tr- # r,r,= f t,:, r c I {'w:, dri,j c! ._ _✓ i 1 ed f!ir use CID d e l::e EF1d F,a,1
s. # c,pes ru _, :,) The t'a F, =_c, i I i r:-.3 4'-artt i ty v j r: e;!ces _ :,f am i, ur,tt
a e rule
Cut—:,ff fr eFtchl:
j`i cut —:,FT' tr-erlch (w-.-,£ri - -pr c . f i e'=; chi -a 1 I be: i ri5ta1 1 =•j aC sh_-.WFi I rl
tr,e r,I r:S.
C r,rs5t.-ti: t i clF-I:
Cc
Fist r-uCtl+:,rf f e::Ca`/ate=j and Ea.'trifi 11 areas Ghat I bc- pE!-f':'rinedi +i}
the near I ! rie5 ar1U :, ra,-C•= ? C r+ 1 Cri rted D e v I at I --- rt5 f r ,=,rn th 15 w I 1 1
r E=�u +.'r- apr,rc,- a I c'f the Garthif i I I 5rla i I bC- p 1 ace, i rr
rna::r. { r_•' I IftC arld r:,t r,IacP-d Iri staridir:` :LRtC- ( rfti+aCtll,:+ri ch:a1 l CC
1 y + hl 1? [ I I t : Lr [ t i '.+ rl R _- s-- i �+ I li C' rl {. +_, Y- �a 1 1 E Lam' �+ G - T '_ !' Y Y' + I I C
# acC-m=r,t. The eifit'arif-:rnerit i,f tr:e I a c. r, Chat I t+e ! r:Cta i I ed uC I rl'�
the rn,_':-e ifrtr'e vi,.'LC rFtate rIaI i:,F.SLr-uctic,r: _+f fill h e i tS ana!I
iric 1 u,'= ten fly:) r'erceF1t T,or se tt 1 emeFit. fc' r'rc,yect a—i i r,st seeraqe,
:.'her, areas c'f urisu l tatt l e mate'-' a: are 1=1-iCCtIJrlter-E?tA they 'r1# 1 1 rleet +
bC, e;;c?'•,ratEiI aro I rl I FE.tirll _,f =,rsP ( 1 ) fC++.+t I+P I C+4' jr-a, e arld h'rc kf ! i 1 ed ar,d
c+ - +rli P. .0 �?'� WIt1': .r--�t.. "} ap,F,r-ii':ej r:;a Ia1 { IL-r-I....l Jim *r: lREfer' to the Cie
!rivestigat ioFi Irif! rinatl,3rt Irl tlil= Iar:S f r 5Pe(:IaI C.-Ir:Cider-at ior.,s.
P r e c a u t i _,r15 5h1,-'L' I d be taL;;Eri dUr- I rt' c or15 trust i on „: _< r; e .-ent e::CeSS I `Je
eY 1:1 C. I i!r: arl+ 5ed I Fri eri+' a t I c,rl.4.
aff-IC4 7>fG/3:. C-71/GO.�w/TL ZL�. USA
SG n.�TG�rFFc Fi�on /3�/t/1o,J P/7- WO2 ��,¢ I' 4-1NCr,
%Ic—sEtat I ort:
------------
AI I e;:r,,:=e,j erflt,ari�:r:-ierjt -:r: =+thc- rare Cc,riStructed areas 5r,a1 i be
5eedect the F+I armed tyre o ve =t=t i+1r: a 5'-'+art a5 r,+ass I t 1 e _ftMr
c'=,ri5-t _tic,ri ELCC+_er`rlj-I t_ cE.lfr``=r'C- cificati F1C5 5rIE-Nt.

-----------------------
AF�E� TCl BE SEED��� I'5 4CRES
i SE THE SEED MIXTURE INDICATED:
0 C L8S. F���� G�ASS � 60 L�s./A C ���E
(8EST SU��ED OM CLAYEY OR WET �OIL C0NDITION�)
SEEDJ�,i8 DATES: S-EPTE^�-DER 15 TO H1__fVE�F-_�ER 3fjp
'PENSACOLA^ 8AHIA GR-,�,.B5 @ 60 L8S./ACRE
(SEE FOOTNOTE r:1D. -1)
SEEDING DATES: �ARCH lf. TO JUNE 30
12 LBS. HULLED B��p�DA (�RA�� � �} �-E:S./AIC:
'
(S LIITED F[)R 11OST 9lUN�)
SEEDIHG DATE£: A PRIL TO JULY 31
0 L8S' RYE GRAIN @ 30 LBS.//\CE �NURSERY FOR FEqCUE)
60 LBS. RiE 8��SS � �0 L�S'/�C�E (TEM�ORARY VEGETATI���
SEEDIriG DATEBr TO �ARC,H 30
L8S'
APPLY THE F0LLOWIN8:
15O0 Li-::-Z?. OF FERTILIZER (lO00
3 TO�S O� DUL��I7lC �-IME (2 �O�S/AC�E)
150 BAL�S 1 _- I F SMALL GRP,lN STRA� ( i 00 DALPS. A��E)
At-L SURFAC-E DRAINS SHOtJI.-D DE l�.,ISTALLED PRIOR TO SEEDIt,.G' 5 �4.APE
ALl_ DISTURBED AREA IMMEDIATE"LY AFTE-: EARTH MQVIN8 IS C��PLET��.
APPLY LIPIE ANID FERTILIZER' THENI DISK TO PIREPARE A 3 TO 4 INCH
SnOOTH 'SEED DED' AF'PSEED Ari D FIED8E� NlTH A CLl TIPAC���
OR SIMlLAR E��lPMENT. �PPLY ��LCn A�D �E�yP�L WITH A M�LC�
ANCHORING TO0- OR r,�ETTTNG'
1. PENSACOLA BAHIAGRASS IS TO ESTABLISH THAN COMMCIN
BERMUDA GRASS. WHEN USING 8AHI'�, IT IS RECOPIMENDED THAT O
LDr:3./ACRE CIF COMMON BERMUDA BE TO PROVlDE CUVER
UNTIL BAHIP.8RASS IS EcSTA_!::LISHE_r.

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
Ray Beasley
Yorick Nursery
38 Turkey Oak Farm Rd
White Oak NC 28399
Dear Ray Beasley:
!W'A
A4 •
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
December 30, 1999
RECEI EED
=a �; 10 2000
FAME-uEviLLE
REG. CFFICE
Subject: Fertilizer Application Recordkeeping
Animal Waste Management System
Facility Number 9-64
Bladen County
This letter is being sent to clarify the recordkeeping requirement for Plant Available Nitrogen (PAN)
application on fields that are part of your Certified Animal Waste Management Plan.
In order to show that the agronomic loading rates for the crops being grown are not being exceeded, you
must keep records of all sources of nitrogen that are being added to these sites. This would include nitrogen
from all types of animal waste as well as municipal and industrial sludges/residuals, and commercial €ertihzers.
Beginning January 1, 2000, all nitrogen sources applied to land receiving animal waste are required to
be kept on the appropriate recordkeeping forms (i.e. IRR1, IRR2, DRYI, DRY2, DRYS, SLUR1, SLUR2,
SLDI, and SLD2) and maintained in the facility records for review. The Division of Water Quality (DWQ)
compliance inspectors and Division of Soil and Water operation reviewers will review all recordkeeping during
routine inspections. Facilities not documenting all sources of nitrogen application will be subject to an
appropriate enforcement action.
Please be advised that nothing in this letter should be taken as removing from you the responsibility or
liability for failure to comply with any State Rule, State Statute, Local County Ordinance, or permitting
requirement.
If you have any questions regarding this letter, please do not hesitate to contact Ms. Sonya Avant of the
DWQ staff at [phone] ext. 571.
/0-;-�
Kerr T. Stevens, Director
Division of Water Quality
cc: Fayetteville Regional Office
Bladen County Soil and Water Conservation District
Facility File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] Fax [phone]w8
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
December 1, 1999
CERTIFIED MAIL
_RETURN RECEIPT_ REQUESTED
Ray Beasley
Yorick Nursery
38 Turkey Oak Farm Rd
White Oak NC 28399
Farm Number: 09 - 64
Dear Ray Beasley:
• •
A�A
AV-ft&MW �g
0--ftft�SWO
NCDIENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NA;rURAL RESOURCES
You are hereby notified that Yorick Nursery, in accordance with G.S. 143-215.1OC, must apply for coverage under
an Animal Waste Operation General Permit. Upon receipt of this letter, your farm has sixty (60) days to submit the attached
application and all supporting documentation. In accordance with Chapter 626 of 1995 Session Laws (Regular Session
1996), Section 19(c)(2), any owner or operator who fails to submit an application by the date specified by the
Department SHALL NOT OPERATE the animal waste system after the specified date. Your application must be
returned within sixty (60) days of receipt of this letter. Failure to submit the application as required may also subject your
facility to a civil penalty and other enforcement actions for each day the facility is operated following the due date of the
application.
The attached application has been partially completed using information listed in your Animal Waste Management
Plan Certification Form. If any of the general or operation information listed is incorrect please make corrections as noted on
the application before returning the application package. The signed original application, one copy of the signed application,
two copies of a general location map, and two copies of the Certified Animal Waste Management Plan must be returned to
complete the application package. The completed package should be sent to the following address:
North Carolina Division of Water Quality
Water Quality Section
Non -Discharge Permitting Unit
1617 Mail Service Center
Raleigh, NC 27699-1617
If you have any questions concerning this letter, please call Dianne Thomas at [phone] extension 364 or
Jeffery Brown with the Fayetteville Regional Office at [phone].
Since , y,
for Kerr T. Stevens
cc: Permit File (w/o encl.)
Fayetteville Regional Office (w/o encl.)
1617 Mail Service Center, Raleigh, NC 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

State of North Carolina
Department of Environment,
Health and Natural Resources
James B. Hunt, Jr., Governor
Jonathan B. Howes, Secretary
November 13, 1996
Ray Beasley
Yorick Nursery
PO Box 31
Elizabethtown NC 28337
SUBJECT: Operator In Charge Designation
Facility: Yorick Nursery
Facility ID#: 9-64
Bladen County
Dear Mr. Beasley:
Nov 19 1996
F ref tl i i
Senate Bill 1217, An Act to Implement Recommendations of the Blue Ribbon Study
Commission on Agricultural Waste, enacted by the 1996 North Carolina General Assembly,
requires a certified operator for each animal waste management system that serves 250 or more
swine by January 1, 1997. The owner of each animal waste management system must submit a
designation form to the Technical Assistance and Certification Group which designates an
Operator in Charge and is countersigned by the certified operator. The enclosed form must be
submitted by January 1, 1997 for all facilities in operation as of that date. Failure to designate a
certified operator for your animal waste management system is a violation of 15A NCAC 2H
.0224 and may result in the assessment of a civil penalty.
If you have questions concerning operator training or examinations for certification, please
contact your local North Carolina Cooperative Extension Service agent certification,
our office.
Examinations have been offered on an on -going basis in many counties throughout the state for
the past several months and will continue to be offered through December 31, 1996.
Thank you for your cooperation. If you, have any questions concerning this requirement please
call Beth Buffington or Barry Huneycutt of our staff at 919/733-0026.
Sincerely,
A. reston Howard, Jr., P.E., Dir for
Division of Water Quality
Enclosure
cc: Fayetteville Regional Office
Water Quality Files
P.O. Box 27687, IK 4
Raleigh, North Carolina 27611-7687 ��C An Equal Oppor#unitylAffirmative Action Employer
Voice 919-715-4100 - 50% recycled/10% post -consumer paper