090009_CORRESPONDENCE_20171231

Murphy -Brown, LLC
Grower(s):
Farm Name:
4/2/2009
NUTRIENT UTILIZATION PLAN
Murphy Brown, LLC
Cypress Creek Nursery AW
County: Bladen
Farm Capacity:
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder 8000
Wean to Finish
Feeder to Finish
Storage Structure:
Storage Period:
Application Method:
Anaerobic Lagoon
>180 days
Irrigation
160
P.O. Box 85
Warsaw, NC 28398
0920
0W—FAYETi!Eii u HffiV , t]IQ
KECEIVED / DENR / DWQ
Agi,ifPr Profpction Sertiott
APR 0 6 2003
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner.
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission.
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft3, tons, etc.):
Capacity . Type Waste Produced per Animal Total
Farrow to Wean 3212 gal/yr gal/yr
Farrow to Feeder 4015 gallyr gallyr
Farrow to Finish 10585 gaVyr gallyr
8000 Wean to Feeder 223 gallyr 1,784,000 gallyr
Wean to Finish 838 gaVyr gallyr
Feeder to Finish 1 986 gallyr I gallyr
Total 1,784,000 gallyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs):
Capacity Type —Nitrogen Produced per Animal Total
Farrow to Wean 5.4 Ibslyr Ibslyr
Farrow to Feeder 6.5 Ibslyr Ibslyr
Farrow to Finish 26 Ibs/yr Ibslyr
8000 Wean to Feeder 0.48 Ibslyr 3,840 Ibslyr
Wean to Finish 1.96 Ibslyr Ibslyr
Feeder to Finish 2.3 Ibslyr I Ibslyr
Total 3,840 Ibs/yr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 38.22
Total N Required 1st Year: 5162.12
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops: 5,162.12
Total Nitrogen Produced by Farm: 3,840.00
Nitrogen Balance for Crops: (1,322.12)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2of8

Reception Area Specifications
Tract Field Irrigated Soil Ist .. Time to IstCrop istCrop
Acreage Typo Code Apply Yield lbs NtUnit Residual IA. Utill..d
3(b) ❑f 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass_ This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized 1 unit yield
A
Barley
1.6 lbs N 1 bushel
B
Hybrid Bermudagrass - Grazed
50 lbs N 1 ton
C
Hybrid Bermudagrass - Hay
50 lbs N 1 ton
D
Corn - Grain
1.25 lbs N 1 bushel
E
Corn - Silage
12 lbs N 1 ton
F
Cotton
0.12 lbs N 1 lbs lint
G
Fescue - Grazed
50 lbs N 1 ton
H
Fescue - Hay
50 lbs N 1 ton
I
Oats
1.3 lbs N 1 bushel
J
Rye
2.4 lbs N 1 bushel
K
Small Grain - Grazed
50 lbs N / acre
L
Small Grain - Hay
50 lbs N 1 acre
M
Grain Sorghum
2.5 lbs N I cwt
N
Wheat
2.4 lbs N 1 bushel
O
Soybean
4.0 lbs N 1 bushel
P
Pine Trees
40 lbs N 1 acre 1 yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm $ ecifications PAN! r/animal Farm Totall r
Farrow to Wean 0.84
Farrow to Feeder 1
Farrow to Finish 4.1
8000 Wean to Feeder 0.072 576
Wean to Finish 0.306
Feeder to Finish 0.36
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 576 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 2880 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 9 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 23.04 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids_ The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
'This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for >180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5of8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract
Hydrant
Type
Crop
_ inlhr
_ inches
T2222
1
Ca
G
0.4
1
T2222
2
Ro
G
0.35
1
T2222
3
Ro
G
0.35
1
T2222
4
Ro
G
0.35
1
Cyp. Creek
5
Ro
G
0.35
1
6
LeA
Q
0.65
1
6 of 8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm:
Owner:
Manager:
Owner/Manager Agreement:
Cypress Creek Nursery AWS090009
Murphy Brown, LLC
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
I/we understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner: Murphy - Brown, LLC
Signature:
Date
Name of Manager (if different from owner): David Nordin
Signature:
Date
Name of Technical Specialist: Toni W. King
Affiliation: Murphy -Brown, LLC.
Address: 2822 Hwy 24 West, PO Drawer 856
Warsaw, NC 28398
Telephone: �910) 293-3434
Signature:
Date
8of8

Additional Comments:
This plan is written by pulls. No crop change or change in acreage. Pull 6
is optional. On pull 6 grower may also have a small grain at the rate of 75
Ibs. N per acre if grazing or 100 Ibs. N if harvesting for hay. if small grain
is following soybeans, deduct 15 Ibs. N for residual N.
7 of 8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing himlher the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recievinq crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See "Weather and Climate in North Carolina" for
guidance).
7 Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
8 Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters.
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist". Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2of3

NUTRIENT UTILIZATION PLAN u RFCEIUED
REQUIRED SPECIFICATIONS
1.PR 0 120
(continued) M_FAl'E1T131i1a
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels. pH shall be adjusted and maintained for optimum crop
production_ Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3 of 3

o�o� WA��9p�
C
Murphy Farms LLC
Cypress Creek Nursery Farm
PO Box 759
Rose Hill, NC 28458
Michael F. Easley, Governor
William G. Ross Jr.. Secretary
Notch Carolina Department of Environment and Natural Resources
Coleen H. Sullins Director
Division of water Quality
August 11, 2008
Subject: Sludge Compliance Requirement Change
Dear Permittee:
In accordance with Condition III.19 of State General Permit AWG100000, your facility is
required to maintain compliance regarding sludge accumulation in your animal waste treatment
lagoon(s). As you know, the previous compliance limit was to have a minimum of four (4) feet
of treatment depth between the designed stop pump and the average elevation of the top of the
sludge blanket. This requirement was based on NRCS Standard No. 359, which was recently
modified.
As of July 2008, Standard No. 359 does not use the 4-foot requirement. Sludge compliance is
now to be based on the sludge volume as a percentage of the total treatment volume. The revised
Standard states that sludge accumulation in the permanent treatment zone must be less than 50%
of the planned treatment volume. Also, there must be a minimum of 2.5 feet of liquid above the
sludge at the pump intake location. If either of these conditions is not met then sludge must be
removed or managed in accordance with an approved Plan of Action for Lagoon Sludge
Reduction (POA). A new sludge survey worksheet has been developed to calculate sludge and
treatment volumes to determine compliance.
Our records indicate that you have filed a Sludge POA for one or more of the lagoons at your
facility. Based on the changes to the sludge requirements in Standard No. 359, your lagoon(s)
may already be in compliance without any sludge removal. Using your lagoon design (or as -
built information) and current sludge survey measurements, complete the NEW sludge survey
worksheet. If you have any difficulty in locating or understanding your lagoon design
information, please contact your technical specialist or county Soil & Water office.
on
e Carotin
Naturally
turally
Aquifer Protection Section 1636 Mail Service Center Raleigh, NC 27699-1636 Telephone: [phone]
Internet: www.newateruuality.orrg Location: 2728 Capital Boulevard Raleigh, NC 27604 Fax l: [phone]
Fax 2: [phone]
An Equal Opportunity/Affirmative Action Employer— 50% Recyded110% Post Consumer Paper

Send both sludge survey worksheets, OLD and NEW, to the address below if you feel that your
lagoon(s) is in compliance and wish to withdraw your POA. Our staff will review the
information and notify you of our decision.
NCDENR — DWQ Animal Feeding Operations Unit
1636 Mail Service Center
Raleigh, North Carolina 27699-1636
Telephone number: [phone]
If you have any questions about the new sludge requirement, sludge survey worksheet, or any
related matter please feel free to contact the Animal Feeding Operations Unit staff at 919-733-
3221.
Sincerely,
Keith Larick, Supervisor
Animal Feeding Operations Unit
Enclosures
cc (w/o enclosures): Bladen County Soil and Water Conservation District
Fayetteville Regional Office, Aquifer Protection Section
AFO Unit Central Files - AWS090009

-# o S=a 4 -
Murphy -Brown, LLC 6/18/2007 P.O. Box 856
Warsaw, NC 28398
NUTRIENT UTILIZATION PLAN
Growers):
Farm Name:
Murphy Brown, LLC
Cypress Creek Nursery
County: Bladen
Farm Ca aci :
Farrow to Wean
Farrow to Feeder
Farrow to Finish
Wean to Feeder 8000
Wean to Finish
Feeder to Finish
Storage Structure: Anaerobic
Storage Period:
Application Method:
>180 days
Irrigation
Lagoon
AW S090009
MAY 2320
L
The waste from your animal facility must be land applied at a specified rate to prevent pollution
of surface water and/or groundwater. The plant nutrients in the animal waste should be used
to reduce the amount of commercial fertilizer required for the crops in the fields where the waste
is to be applied.
This waste utilization plan uses nitrogen as the limiting nutrient. Waste should be analyzed
before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize
the fertilizer value of the waste and to ensure that it is applied in an environmentally safe manner:
1. Always apply waste based on the needs of the crop to be grown and the nutrient
content of the waste. Do not apply more nitrogen than the crop can utilize.
2. Soil types are important as they have different infiltration rates, leaching potentials,
cation exchange capacities, and available water holding capacities.
3. Normally waste shall be applied to land eroding at less than 5 tons per acre per
year. Waste may be applied to land eroding at 5 or more tons per acre annually, but
less than 10 tons per acre per year providing that adequate filter strips are established.
4. Do not apply waste on saturated soils, when it is raining, or when the surface is frozen.
Either of these conditions may result in runoff to surface waters which is not allowed
under DWQ regulations.
5. Wind conditions should also be considered to avoid drift and downwind odor
problems.
6. To maximize the value of the nutrients for crop production and to reduce the potential
for pollution, the waste should be applied to a growing crop or applied not more than
30 days prior to planting a crop or forages breaking dormancy. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
1 of 8

This plan is based on the waste application method shown above. If you choose to change
methods in the future, you need to revise this plan. Nutrient levels for different application
methods are not the same.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. In some cases you may want to have plant analysis made, which could
allow additional waste to be applied. Provisions shall be made for the area receiving waste to
be flexible so as to accommodate changing waste analysis content and crop type. Lime must
be applied to maintain pH in the optimum range for specific crop production.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC
2H .0217 adopted by the Environmental Management Commission_
AMOUNT OF WASTE PRODUCED PER YEAR ( gallons, ft3, tons, etc.) -
Capacity Type
Waste Produced per Animal
Total
Farrow to Wean
3212 gallyr
gallyr
Farrow to Feeder
4015 gailyr
gallyr
Farrow to Finish
10585 gallyr
gallyr
8000 Wean to Feeder
223 gallyr
1,784,000 gallyr
Wean to Finish
838 gallyr
gallyr
Feeder to Finish
986 gallyr
I galyr
Total
1,784,000 gallyr
AMOUNT OF PLANT AVAILABLE NITROGEN PRODUCED PER YEAR (lbs):
Capacity Type
Nitrogen Produced per Animal
Total
Farrow to Wean
5.4 Ibs/yr
Ibs/yr
Farrow to Feeder
6.5 lbstyr
lbs/yr
Farrow to Finish
26 lbstyr
lbstyr
8000 Wean to Feeder
0AB Ibslyr
3,B40 Ibslyr
Wean to Finish
1.96 Ibslyr
lbstyr
Feeder to Finish
2.3 Ibslyr
Ibslyr
Total
3,840 Ibslyr
Applying the above amount of waste is a big job. You should plan time and have appropriate
equipment to apply the waste in a timely manner.
LAND UTILIZATION SUMMARY
The following table describes the nutrient balance and land utilization rate for this facility
Note that the Nitrogen Balance for Crops indicates the ratio of the amount of nitrogen produced
on this facility to the amount of nitrogen that the crops under irrigation may uptake and utilize
in the normal growing season.
Total Irrigated Acreage: 38.22
Total N Required 1st Year: 5162.12
Total N Required 2nd Year: 0
Average Annual Nitrogen Requirement of Crops: 5,162.12
Total Nitrogen Produced by Farm: 3,840.00
Nitrogen Balance for Crops: (1,322,12)
The following table describes the specifications of the hydrants and fields that contain the crops
designated for utilization of the nitrogen produced on this facility. This chart describes the size,
soil characteristics, and uptake rate for each crop in the specified crop rotation schedule for this
facility.
2 of 8

_utilizad
3(b) of 8

This plan does not include commercial fertilizer. The farm should produce adequate plant
available nitrogen to satisfy the requirements of the crops listed above.
The applicator is cautioned that P and K may be over applied while meeting the N requirements.
In the future, regulations may require farmers in some parts of North Carolina to have a nutrient
management plan that addresses all nutrients. This plan only addresses nitrogen.
In interplanted fields ( i.e. small grain, etc, interseeded in bermuda), forage must be removed
through grazing, hay, and/or silage. Where grazing, plants should be grazed when they
reach a height of six to nine inches. Cattle should be removed when plants are grazed to a
height of four inches. In fields where small grain, etc, is to be removed for hay or silage, care
should be exercised not to let small grain reach maturity, especially late in the season (i.e.
April or May). Shading may result if small grain gets too high and this will definately interfere
with stand of bermudagrass. This loss of stand will result in reduced yields and less nitrogen
being utilized. Rather than cutting small grain for hay or silage just before heading as is
the normal situation, you are encouraged to cut the small grain earlier. You may want to
consider harvesting hay or silage two to three times during the season, depending on the
time small grain is planted in the fall.
The ideal time to interplant small grain, etc, is late September or early October. Drilling is
recommended over broadcasting. Bermudagrass should be grazed or cut to a height of
about two inches before drilling for best results.
CROP CODE LEGEND
Crop Code
Crop
Lbs N utilized 1 unit yield
A
Barley
1.6 lbs N 1 bushel
B
Hybrid Bermudagrass - Grazed
50 lbs N 1 ton
C
Hybrid Bermudagrass - Hay
50 lbs N 1 ton
D
Com - Grain
1.25 lbs N 1 bushel
E
Com - Silage
12 lbs N 1 ton
F
Cotton
0.12 lbs N / Ibs lint
G
Fescue - Grazed
50 lbs N / ton
H
Fescue- Hay
50 lbs N / ton
I
Oats
1.3 lbs N / bushel
J
Rye
2.4 lbs N 1 bushel
K
Small Grain - Grazed
50 lbs N / acre
L
Small Grain - Hay
50 lbs N 1 acre
M
Grain Sorghum
2.5 lbs N 1 cwt
N
Wheat
2.4 lbs N 1 bushel
O
Soybean
4.0 lbs N / bushel
P
Pine Trees
40 lbs N 1 acre / yr
Acres shown in the preceding table are considered to be the usable acres excluding
required buffers, filter strips along ditches, odd areas unable to be irrigated, and perimeter areas
not receiving full application rates due to equipment limitations. Actual total acres in the fields
listed may, and most likely will be, more than the acres shown in the tables.
See attached map showing the fields to be used for the utilization of animal waste.
4of8

SLUDGE APPLICATION:
The following table describes the annual nitrogen accumulation rate per animal
in the lagoon sludge
Farm Specifications PAN/ rlanimal Farm Totall r
Farrow to Wean 0.84
Farrow to Feeder 1
Farrow to Finish 4.1
8000 Wean to Feeder 0.072 576
Wean to Finish 0.306
Feeder to Finish 0.36
The waste utilization plan must contain provisions for periodic land application of sludge at
agronomic rates. The sludge will be nutrient rich and will require precautionary measures to
prevent over application of nutrients or other elements. Your production facility will produce
approximately 576 pounds of plant available nitrogen per year will accumulate in the lagoon
sludge based on the rates of accumulation listed above.
If you remove the sludge every 5 years, you will have approximately 2880 pounds of plant
available nitrogen to utilize. Assuming you apply this PAN to hybrid bermuda grass hayland at the
rate of 300 pounds of nitrogen per acre, you will need 9 acreas of land. If you apply the sludge
to corn at a rate of 125 pounds per acre, you will need 23.04 acres of land. Please note that these
are only estimates of the PAN produced and the land required to utilize that PAN. Actual values
may only be determined by sampling the sludge for plant available nitrogen content prior to application
Actual utilization rates will vary with soil type, crop, and realistic yield expectations for the specific
application fields designated for sludge application at time of removal.
APPLICATION OF WASTE BY IRRIGATION:
The irrigation application rate should not exceed the intake rate of the soil at the time of irrigation
such that runoff or ponding occurs. This rate is limited by initial soil moisture content, soil
structure, soil texture, water droplet size, and organic solids. The application amount should not
exceed the available water holding capacity of the soil at the time of irrigation nor should the
plant available nitrogen applied exceed the nitrogen needs of the crop.
If surface irrigation is the method of land application for this plan, it is the responsibility of the
producer and irrigation designer to ensure that an irrigation system is installed to properly
irrigate the acres shown in the preceding table. Failure to apply the recommended rates and
amounts of nitrogen shown in the tables may make this plan invalid.
'This is the maximum application amount allowed for the soil assuming the amount
of nitrogen allowed for the crop is not over applied. In many situations, the application
amount shown cannot be applied because of the nitrogen limitation. The maximum
application amount shown can be applied under optimum soil conditions.
Your facility is designed for > 180 days of temporary storage and the temporary storage must
be removed on the average of once every 6 months. In no instance should the volume of the
waste stored in your structure be within the 25 year 24 hour storm storage or one foot of
freeboard except in the event of the 25 year 24 hour storm.
It is the responsibility of the producer and waste applicator to ensure that the spreader equipment
is operated properly to apply the correct rates to the acres shown in the tables. Failure to apply
the recommended rates and amounts of nitrogen shown in the tables may make this plan invalid.
Call your technical specialist after you receive the waste analysis report for assistance in
determining the amount of waste per acre and the proper application prior to applying the waste.
5of8

Application Rate Guide
The following is provided as a guide for establishing application rates and amounts.
Soil
Application Rate
Application Amount
Tract
Hydrant
Type
Crop
_ inlhr
inches
T2222
1
Ca
G
0.4
1
T2222
2
Ro
G
0.35
1
T2222
3
Ro
G
0.35
1
T2222
4
Ro
G
0.35
1
Gyp. Creek
5
Ro
G
0.35
1
6
LeA
O
0.65
1
6of8

NUTRIENT UTILIZATION PLAN CERTIFICATION
Name of Farm
Owner:
Manager:
Owner/Manager Agreement:
Cypress Creek Nursery AWS090009
Murphy Brown, LLC
I/we understand and will follow and implement the specifications and the operation and
maintenance procedures established in the approved animal waste nutrient management
plan for the farm named above. I/we know that any expansion to the existing design capacity
of the waste treatment and/or storage system, or construction of new facilities, will require a
new nutrient management plan and a new certification to be submitted to DWQ before the new
animals are stocked.
Ilwe understand that I must own or have access to equipment, primarily irrigation equipment,
to land apply the animal waste described in this nutrient management plan. This equipment
must be available at the appropriate pumping time such that no discharge occurs from the lagoon
in the event of a 25 year 24 hour storm. I also certify that the waste will be applied on the land
according to this plan at the appropriate times and at rates which produce no runoff.
This plan will be filed on site at the farm office and at the office of the local Soil and Water
Conservation District and will be available for review by NCDWQ upon request.
Name of Facility Owner:
Signature:
Murphy- Brown, LLC
Name of Manager (if different from owner): David Nordin
Signature:
Date
Date
Name of Technical Specialist: Toni W. King _
Affiliation: Murphy -Brown, LLC.
Address: 2822 Hwy 24 West, PO Drawer 856 _
Warsaw, NC 28398 ^^
Telephone: [phone]
Signature:
. U'�. V--�
as D-1
Date
8of8

Additional Comments:
This plan is written by pulls. No crop change or change in acreage. Pull $
is optional. On pull 6 grower may also have a small grain at the rate of 75
Ibs. N per acre if grazing or 100 Ibs. N if harvesting for hay. If small grain
is following soybeans, deduct 15 Ibs. N for residual N.
7 of 8

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
Animal waste shall not reach surface waters of the state by runoff, drift, manmade
conveyances, direct application, or direct discharge during operation or land application.
Any discharge of waste which reaches surface water is prohibited.
2 There must be documentation in the design folder that the producer either owns or has an
agreement for use of adequate land on which to properly apply the waste. If the producer
does not own adequate land to properly dispose of the waste, he/she shall provide
evidence of an agreement with a landowner, who is within a reasonable proximity,
allowing him/her the use of the land for waste application. It is the responsibility of the
owner of the waste production facility to secure an update of the Nutrient Utilization Plan
when there is a change in the operation, increase in the number of animals, method of
application, recievinq crop type, or available land.
3 Animal waste shall be applied to meet, but not exceed, the nitrogen needs for realistic crop
yields based upon soil type, available moisture, historical data, climatic conditions, and
level of management, unless there are regulations that restrict the rate of applications for
other nutrients.
4 Animal waste shall be applied to land eroding less than 5 tons per acre per year. Waste
may be applied to land eroding at more than 5 tons per acre per year but less than 10 tons
per acre per year provided grass filter strips are installed where runoff leaves the field (See
USDA, NRCS Field Office Technical Guide Standard 393 - Filter Strips).
5 Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when there is danger of drift from the land application field.
When animal waste is to be applied on acres subject to flooding, waste will be soil
incorporated on conventionally tilled cropland. When waste is applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not occur
during a season prone to flooding (See '"Weather and Climate in North Carolina" for
guidance).
Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff
does not occur offsite or to surface waters and in a method which does not cause drift
from the site during application. No ponding should occur in order to control odor and flies.
Animal waste shall not be applied to saturated soils, during rainfall events, or when the
surface is frozen.
1 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
9 Animal waste shall be applied on actively growing crops in such a manner that the crop is
not covered with waste to a depth that would inhibit growth. The potential for salt damage
from animal waste should also be considered.
10 Nutrients from waste shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste/nutrient loading rates on these soils should be
held to a minimum and a suitable winter cover crop planted to take up released nutrients.
Waste shall not be applied more than 30 days prior to planting of the crop or forages
breaking dormancy.
11 Any new swine facility sited on or after October 1, 1995 shall comply with the following:
The outer perimeter of the land area onto which waste is applied from a lagoon that is a
component of a swine farm shall be at least 50 feet from any residential property boundary
and canal. Animal waste, other than swine waste from facilities sited on or after October 1,
1995, shall not be applied closer than 25 feet to perennial waters_
12 Animal waste shall not be applied closer than 100 feet to wells.
13 Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14 Waste shall be applied in a manner not to reach other property and public right-of-ways.
15 Animal waste shall not be discharged into surface waters, drainageways, or wetlands by
discharge or by over -spraying. Animal waste may be applied to prior converted cropland
provided the fields have been approved as a land application site by a "technical
specialist'. Animal waste shall not be applied on grassed waterways that discharge
directly into water courses, and on other grassed waterways, waste shall be applied at
agronomic rates in a manner that causes no runoff or drift from the site.
16 Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall
not be discharged into the animal waste management system.
2 of 3

NUTRIENT UTILIZATION PLAN
REQUIRED SPECIFICATIONS
(continued)
17 A protective cover of appropriate vegetation will be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). Areas shall be fenced, as necessary, to
protect the vegetation. Vegetation such as trees, shrubs, and other woody species, etc.,
are limited to areas where considered appropriate. Lagoon areas should be kept mowed
and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18 If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
19 Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks and spills. A regular maintenance checklist should be
kept on site.
20 Animal waste can be used in a rotation that includes vegetables and other crops for direct
human consumption. However, if animal waste is used on crops for direct human
consumption, it should only be applied pre -plant with no further applications of animal
waste during the crop season.
21 Highly visible markers shall be installed to mark the top and bottom elevations of the
temporary storage (pumping volume) of all waste treatment lagoons. Pumping shall be
managed to maintain the liquid level between the markers. A marker will be required to
mark the maximum storage volume for waste storage ponds.
22 Waste shall be tested within 60 days of utilization and soil shall be tested at least annually
at crop sites where waste products are applied. Nitrogen shall be the rate -determining
nutrient, unless other restrictions require waste to be applied based on other nutrients,
resulting in a lower application rate than a nitrogen based rate. Zinc and copper levels in
the soil shall be monitored and alternative crop sites shall be used when these metals
approach excessive levels, pH shall be adjusted and maintained for optimum crop
production. Soil and waste analysis records shall be kept for a minimum of five years.
Poultry dry waste application records shall be maintained for a minimum of three years.
Waste application records for all other waste shall be maintained for a minimum of five
years.
23 Dead animals will be disposed of in a manner that meets North Carolina regulations.
3 of 3

' is �.,r'�• 4qL-
4 1 1. '1l �,. ��•
. ''•w 1�''�+r'~�'�l+'�',r ram'~r ,� ti r••'r
J �• i f' ft old 'l�ii.{.. •�•• �`�1 �• i' '
0*4
1.4
it
\rj• - � i 'tilt `' �f�iP .'r/� 1. ii � �/
•, ' !vi.%j'd�.'�.,.f/ y�'1 � •`p :► � i:.'� 1.1, ,l• ti .. ,' j, 1.
' .� il�• ,'� „,}'D.1.1; �.,
.1,.,�.•. ,.. �.S,•i. .+ t 4 .'�'� ,1�'�. h + _7 �l �i.It, { .. r• • it
a �r
r, �, � �r�1 ' �",!?{ ��.1}�� � rl+�.r•�i:.�' �j ` �S': 'f~,1•S N ll:'J�"}� ��.r�'s '' � �' K� l.S,�;� i ; �• .
,' •� �� ��\'t�"��r�;w +'.h..'.r �i,'�f .'iC�.(� t�.l.f ,. � . ,� R,f• •yq'• }��' '�• �':,'
.i 1.1 it � i}f+�s 1,�y "aa"I�/,• '• i� :•l .al•.\ �1'� � � ''i '.i��� :' a>. '_17 �tia•1�`• y� .w
41 �� F ,YZ.I•�� .!t • t `�- .�l,.i tf� r�. r �. • 1=' .,l^ • ,,,
b • 7 r ,/

Waste Management Plan Changes t�r
MAY 2 3 2007
w� sc-�—
1
Facility 0 Farm,�e--
This farms Waste Management Plan has made the following changes:
❑ Crop changes
❑ Wetted Acres
❑ Increased Acreage
❑ Decreased Acreage
❑ Changed Irrigation Design
❑ Change in Farm type
❑ Plan based on 3 Years On Farm Records
Other
Comments:
Date

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
October 1, 2004
Murphy Farms
Cypress Creek Nursery Farm
PO Box 759
Rose Hill NC 28458
Alan W. Klimek, P. E., Director
Division of Water Quality
RECEIVED
OCT 15 2004
DENR-FAYEFfE1RLLE REGIONAL OFRCE
Subject: Certificate of Coverage No. AWS090009
Cypress Creek Nursery Farm
Swine Waste Collection, Treatment,
Storage and Application System
Bladen County
Dear Murphy Farms:
On June 11, 2004, the North Carolina Division of Water Quality (Division) issued a revised State General
Permit for swine facilities. The General Permit was issued in accordance with the directive of Senate Bill
733 (Session Law 2003-28).
In accordance with your application received on February 13, 2003 and in accordance with the directive
of Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to
Murphy Farms, authorizing the operation of the subject animal waste collection, treatment, storage and
land application system in accordance with General Permit AWG100000. The issuance of this COC
supersedes and terminates your previous COC Number AWS090009 which expires October 1, 2004.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Cypress Creek Nursery Farm, located in Bladen County, with an animal
capacity of no greater than an annual average of 8000 Wean to Feeder swine and the application to land
as specified in the facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to
Wean or Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are
unneccessary, they may be replaced by an equivalent number of sows. Any of the sows may be replaced
by gilts at a rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and roust be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Since this is a revised State
General Permit, it contains new requirements in addition to most of the conditions contained in the
previous State General Permit. Enclosed for your convenience is a package containing the new and
revised forms used for record keeping and reporting. Please pay careful attention to the record keeping
and monitoring conditions in this permit.
Aquifer Protection Section - Animal Feeding Operations Unit
1636 Mail Service Center, Raleigh, North Carolina 27699-1638
Phone: [phone] FAX: [phone] / Internet: h2o.enr.state. nc.us
An Equal Opportunity/Affirmative Action Employer - 50% Recyeled110% Post Consumer Paper
NorthCarolina
Naturally

If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 2H .0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100 foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Duane Leith at [phone].
Sincerely,
Zd� ./-
L/
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG 100000)
cc: (Certificate of Coverage only for all cc's)
Fayetteville Regional Office, Aquifer Protection Section
Bladen County Health Department
Bladen County Soil and Water Conservation District
Permit File AW S090009
APS Central Files

Zii !L'Ti4l 5 1., 1

ON
Nd,
e'j"
`4 'X I
VA'
tt:
Null
, k1m, I bi
wt:
Op
lu
W WI=
I
All
IF
t
i

' .�y �. � 1`• ram, f`Sl�ti � + l•, i,
{. i �:'•' • 4 .till, ,- a•r=
1464
ed
'f .. '� +��.' + f. 1 •�� Sri �I� 'l,.,liti b .i w { _}L�z
H, 1
'i '+. �.,_ ' � ?t ��k f;,. 1 �.'•..1� �/A14�a �• ! . 11
•y .t'► AA �� +41`r'+•''S4,°R'/ •Flf�+ ��"• ' •r w :l '�'� �i.'►rr� r'
• d � ari�• � Jtl�'�' � s'1 'f r..� • `�' � • ��'f''' �, '�.� �,t�ry •� r.',���.� �i! r� '� a+!
Xt
oj
,,� �.• a. ".*h 'r., . Ali .�-r .
,f � t � � ,1� li t} r,, � • �� ♦ � ij 1
� ►,�' °I,.M ��,r'114: t�; ifl ��.+.f.' { +J , �_ n \� f y� 1/ '.er
,�- •k��� i! 1 :4 psi •, • ll'�a,} �'�+', • ' ti�,� ''f,r �... ` ,�.
�.�'r ; •��j•F1.�.. � ,.�r. .1. FFF � ,'l:r..r.'�ly;?� ''�•'���, r 1' ,� f
}}} Li M
9, O1 ••.Z ,. J:Y•f+� ,; ,r f#, �,' ,'.i�a i "fir, ;;�'r +'•= "'' ii�
r . y yy i, _4 �. ;� ►,}' "f t�Y f ' � ''•• r' • • � '�''� Y! :�! � ��
{ , / ',�j �N •'1 ~ '+�• .. y,�
' "1
f=i 11 !, r '.��j'r *� ,� ��.: •:,�.'t•,rL,ir,'� r.i Nf}�.1���fi•1.,�'' {..fly) �N.: •.•�,
}�f r:' 4 MT
(1�; .1•.}e1F �. 1 f+r� •. .1��{ .i �fe� �� `r 1 \� '��,*'ri S''� � 1
r• nrr` + + �.'}+i'1�i �}:r' ':1/��. �•�ill '�.!! j' � �`;i�i,�.. 1• ��.al•��iyi'' i � r��Si • ~ .:� f��/� ��, 1•. 7� r.
J• � � �1 1. ! ti .�

State of North Carolina
Department of Environment
and Natural Resources
F Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
Murphy Family Farms
Cypress Creek Nursery Farm
5274 Old Fay Rd
Garland NC 28441
Attn: Toni King
Dear Toni King:
0 •
odd
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
February 26, 1999 RECEIVEj
1 1999
FAY ETT-Vl'LLE
REG. D Fi OZ
Subject: Certificate of Coverage No. AWS090009
Cypress Creek Nursery Farm
Swine Waste Collection, Treatment,
Storage and Application System
Bladen County
In accordance with your application received on February 3, 1999, we are forwarding this
Certificate of Coverage (COC) issued to Murphy Family Farms, authorizing the operation of the subject
animal waste collection, treatment- storane and land application system in accordance with General
Permit AWG100000. This approval shall consist of the operation of this system including, but not
limited to, the management of animal waste from the Cypress Creek Nursery Farm, located in Bladen
County, with an animal capacity of no greater than 8000 Wean to Feeder and the application to land as
specified in the Certified Animal 'Yaste ` lanagement Plan (CAWN14P).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations
as specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals -
Please be advised that any violation of the terms and conditions specified in this COC, the General
Permit or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS
143-215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This
request shall be made within 30 days of notification by the Division.
This COC is not automatically transferable. A name/ownership change application must be
submitted to the- DWQ prior to a name change or change in ownership.
P.O_ Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Certificate of Coverage AWS090009
Cypress Creek Nursery Farm
Page 2
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the
right to apply for an individual non -discharge permit by contacting the engineer listed below for
information on this process. Unless such a request is made within 30 days, this COC shall be final and
binding.
The subject farm is located in the Fayetteville Regional Office. The Regional Office Water
Quality Staff may be reached at [phone]. If you need additional information concerning this
COC or the General Permit, please contact JR Joshi at [phone] ext. 363.
Sincerely, ��-�--�------�--_�_-
�-LI~A. Preston Howard, Jr., P.E.
cc: (Certificate of Coverage only for all cc's)
Bladen County Health Department
Fayetteville Regional Office, Water Quality Section
BIaden County Soil and Water Conservation District
Permit File- Central Files
NDPU Files

State of North Carolina
t Environment REC�=��
60
Department of E o and Natural Resources VJATERQUA-ITYSEC' ION
Division of Water Quality
Non -Discharge Permit Application Form FEB 0 3 1999
(THIS FORM MAY BE PHOTOCOPIED FOR USE AS AN ORIGINAL)
General Permit - Existing Liquid Animal Waste Opera nt.,ge Pettrtitung
The following questions have been completed utilizing information on file with the Division. Please
review the information for completeness and make any corrections which are appropriate. If a
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
1. GENERAL INFORMATION:
1.1 Facility Name: Cypress Creek Nursery Farm
1.2 Print Land Owner's name: Murphy Family Farms
1.3 Mailing address: 5274 Old Fay Rd
City, State: Garland NC
Telephone Number (include area code): 588-4104
Zip: 28441
1.4 County where facility is located: Bladen
1.5 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads. Please include a
copy of a county road map with the Iocation of the farm identified): Take US 701 S. fromGarland 2 blocks S_ from
caution light turn right onto SR 1200 W. toward Bladen Co. at intersection w/ NC 210 turn right onto NC 210 for 0.1 mile
turn left onto SR 1002 for 5.5 miles to farm entrance on right.
1.6 Print Farm Manager's name (if different from Land Owner): Brian Schrock
1.7 Lessee's / Integrator's name (if applicable; please circle which type is listed): Murphy Family Farms _
1.8 Date Facility Originally Began Operation: 01/01/88
1.9 Date(s) of Facility Expansion(s) (if applicable):
2. OPERATION INFORMATION:
2.1 Facility No.. 09 (county number); _9 (facility number).
2.2 Operation Desc tr tot n: Swine operation
Ito Feeder
8000- Certified Design Capacity
Is the above information correct? =yes; no. If no, correct below using the design capacity of the facility
The "No. of Animals" should be the maximum num er or which the waste management structures were designed.
Type of Swine
0 Wean to Feeder
0 Feeder to Finish
0 Farrow to Wean (# sow)
0 Farrow to Feeder (# sow)
0 Farrow to Finish (# sow)
No. of Animals Type of Poultry No. of Animals
0 Layer
Other Type of Livestock on the farm:
0 Non -Layer
0 Turkey
Type of Cattle No. of Animals
0 Dairy
0 Beef
No. of Animals:
FORM: AWO-G-E 5/28/98 Page I of 4 09 - 9

0
2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
system): 50 ; Required Acreage (as listed in the AWMP): 29
2.4 Number o agoo storage ponds (circle which is applicable):
2.5 Are subsurface drains present within 100' of any of the application fields? (::Y:;)or NO (please circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES or 60ease circle one)
2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, N Sta ards, etc.) (Swine Only)
nn YES NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited?
What was the date that this facility's land application areas were sited? iq I
REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to each
item.
licants Initials
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit
application for animal waste operations.
The CAWMP must include the following components:
3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility.
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application-
3.3.4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application field.
3.3.8 The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.3.10 A site schematic.
3.3.11 Emergency Action Plan.
3.3.12 Insect Control Checklist with chosen best management practices noted-
3.3.13 Odor Control Checklist with chosen best management practices noted.
3.3.14 Mortality Control Checklist with the selected method noted.
3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility.
3.3.16 Operation and Maintenance Plan.
If your CAWMP includes any components not shown on this list, please include the
additional components with your submittal.
FORM: AWO-G-E 5/28/98 Page 2 of 4 09 - 9

Eu'=�v
RQ w.
Vj
Facility Number: 09 - 9
Facility Name: Cypress Creek Nursery Farm �6n9,�Q pe�tt[tt►9
4. APPLICANT'S CERTIFICATION•
1, V� �C - • rvt 5 (Land Owner's name listed in question 1.2), attest that
this application for r y v`C (Facility name listed in question 1.1)
has been reviewed by me and ij at -curate and complete to the best of my knowledgeA I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package wil�,be returned to me as incomplete.
Signature ,Ag�
5. MANAGER'S CERTIFICATION:
I,
Date _r!:)- — -:�L—
only if different from the Land Owner)
(Manager's name listed in question 1.6), attest that this
application for (Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed and that if all required supporting information and attachments are not included, this application
package will be returned as incomplete.
Signature
Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
POST OFFICE BOX 29535
RALEIGH, NORTH CAROLINA 27626-0535
TELEPHONE NUMBER: [phone]
FAX NUMBER: [phone]
FORM: AWO-G-E 5/28/98 Page 3 of 4 09 - 9

DIVISION OF WATER QUALITY REGIONAL OFFICES (1/98)
Asheville Regional WQ SupwAsor
59 Woodfin Place
AsheviHe. NC 2880I
[phone]
Fax [phone]
Avery Macon
Buncombe Madison
Burke
McDowell
Caldwell
Mitchell
Cberokee
Polk
Coy
Ruiheriord
Graham
Swain
Haywood
Transylvania
Henderson
Jam
Yancey
Fayetteville Regional WQ Supervisor
Wachovia Building, Suite 714
Fayetteville, NC 28301
(910) 49&1541
Fax [phone]
Washington Regional WQ Supervisor
943 Washington Square Mall
Washington, NC 27999
[phone]
Fax [phone]
Beaufort Jones
Berde Lenoir
Cbowan
Pamilico
Craven
Pasquotank
%AUUu3C1
Pcr: din,ans
Dare .
Pitt
Gates
Tvrdl
Graeae
Washington
Hertford
Wayne
Hyde
Mooresville Regional WQ Supervisor
919 North Main Street
Mooresville, NC 28115
[phone]
Fax [phone]
Raleigh Regional WQ Sgpemum
3800 Ban ztt Dr.
Raleigh, NC 27611
(919) 5714700
Fax [phone]
C3iatham
Nash
Durham
>=dgeccmbe
Northampton
Orange
Franklin
Person
Granville
Vance
iiailasdw
wake
Johnston
WM=
Lee
Wilson
Wilmington Region. WQ Supervisor
127 Cardinal Drive Extension
Wilmington, NC 29405.3845
[phone]
Fax [phone]
Anson Moore Alexander Lincoln Brunswick New Hanover
Blades Richmond Cabarrus Mecklenburg Carteret Onslow
Cumberland Robeson Catawba Rowan Columbus Pender
Haman Sampson Cleveland Stanly Duglin
Hoke Scotland Gaston Union
Montgomery lredell
Winston-Salem Regional WQ Supervisor
585 Waughtown Street
Winston-Salem, NC 27107
(910) 77IA600
Fax [phone]
Aiamance Rockingham
Allegbany Randolph
Ashe
Stokes
Caswell
Story
Davidson
Watauga
Davie
Wilkes
Forsyth
Yadkin
Guilford
FORM: AWO-G-E 5/28/98 Page 4 of 4

General Information:
Name of Farm: G
Owner(s) Name:_
Mailing Address:
Animal Waste Management -Plan Certification
(Please rype or print all information that does not require a signature)
F,a ! Get ►
Facility No: `7 s - S
Phone No: 5$ds - LA 04
Farm Locadom' Fourte-en Digit Hydrologic Unit: 0 p O L-0 (D 5 0 o ZQ
Latitude and Longitude: 3 yr� �t� / '1 31 I—s o___ County:
Please attach a copy of a county road map with location identified and describe below (Be specific:
road names, directions, milepost, 5 Am,( 1 sRu ea
aAr Gwr}a...d. PIKIt e.. CGe 3.3 iA:-1-es;_4v j�.rh ' -kU-4n rk�otit�ZtU�CmQI
\-C- . o^ Se tOtS% . CTo 5.*'— r . r url _
Operation Descrimion:
of Swine No ofAnbnals TypWean to Feeder_
0 Feeder to Finish
0 Farrow to Wean
Q Farrow to Feeder
0 Farrow to Finish
Type ofPaultry No of Animals
dLayer
opullets
Other Type of Livestock -
Type ofCaale No ofdnbnals
ODD
OBeef
Number of Animah:
Acreage Available for Application: b . d Required Acreage: Qj. p
Number of Iagoons/Storage Ponds: �_ Total Capacity: —3&0 Z�e7 Cubic Feet M3)
Are subsurface drains present on the farm: YES or zlM> (please
If YES: are subsurface drains present in the area of the LAGOON o Y ease circle one)
Owner/Manager Agreement
I(we) verify d= all the above information is correct and will be updated upon changing. I (we) understand the operation and maintenance
procedures established in the approved animal waste rnanagemcat plan for the farm named above and will implement these procedures. I (wa)
know that any expansion to the existing design capacity of the waste treatment and storage system or construction of. new facilities will require a
new certification to be submitted to the Division of Hnvirowncrrtal Management before the new animals arc stocked. I (we) understand that these
must be no discharge of animal waste from the storage or application system to surface waters of the state either directly through a man-made
conveyance or from a storm event less severe than the 2-5-year, 24-hour storm and there must not be run-off from the application of animal
waste. I (wc) understand that run-off of pollutants from lounging and heavy use areas must be minimized using tachnical standards developed by
the Natural Resources Conservation Service. The approved plan will be filed at the farm and at the office of the local Soil and Water
Conservation District, I (we) know that modification must be approved by a technical specialist and submitted to the Soil and Water Conservation
District prior to implementation. A change in land ownership requires written notification to DF.M or a new certification (-if the approved plan is
changed) within 60 days of a title transfer.
Name ofR,.
�Cr'q-
SignatureDate: � -15'-9 '1 _
Name of erent from owner):
SignatureDate: -f Q `9 "7
AWC —Ian 1

�echnical -SpeciAUmtTCertifiration
L As a twj=cal specialist designated by the North Carolina Soil.and Water Conservation- Commission pursuant to 15A
NCAC 6F _0005, I certify that the aniz—i waste managmx=t system for -the farm named.above has-an.animW waste
management plan that meets or exceeds standards and specifications of the Division of Environmental. Managment (DEM) as
specified in 15A NCAC 2H.0217 and the USDA -Natural Resources Consmvation Service (NRCS)-and/or the: North Carolina
Soil and Water Conservation Commission pwsuant to ISA NCAC2H.0217-and 15A NCAC 6F .0001-.0005. The following
elements are included in the plan as applicable_ While each category designates . a technical specialist who may sign each
certification (SD, SI, WUP, RC,I) the technical specialist should only certify parts for which, they.am.rMh**c-atty. eompetenL
II_ Certification of Deesi
A) Collection Storage- 'i mtrnent System
Check sire appropriate box
() Existing facility without retrofit (SD. or WUP)
Storage volume is adequate for operation capacity; storage capability consistent with waste.utilizatioa requirements,
New, expanded or retrofitted facility (SD)
ur+�u
Animal waste storage and treatment structures, such as but not limited to collection systems, `� auIW&, have
been designed to meet or exceed the minimum standards and specifications .,,
Name of Technical Specialist (Please Print) J
Affiliation: M..
Uck4G�? Q� SE -AL 9r
Address(Agency A R►Ll YlL Phone No: Z-ZC;�,'"d�•'�;•�`
rrrrr,aru
Signature: Date: 8113A7
B) Land Application Site MUM
The plan provides for minimum separation (buffers); adequate amount of land for waste wilizataion; .chosen crop is
suitable for waste management; hydraulic and nutrient loading rates.
Name of Technical Specialist (Please Pant).
Affiliation:
Address {Agency) • 1 L �5�5� Phone No:
Signature: Date: <?- (Q/9 -7
FIVA
Qretk the priare box
FacAiry without e,
facility does
-o� r lots (SD or WUP or RC)
contain any exterior lots.
{) Facility with exterior lots (RC)
Methods to minimize the run off of pollutants from lounging and heavy use.areas have been designed in accordance
with technical standards developed by MRCS.
Name of Technical Specialist (Please Print): b
Affiliation - 1
Address (Agency): o Phone No.:
'ZS`•t->
Signature: Date: 7- / Fr. cI -7
AWC — ]anaary . -997

.-:A-Aipplicntign and Handlinr&WpMent
Check shre Appropriate boar
(� "aria-. or eManding facilfty'th aisting waste avylication ecuiyment (WUP or I)
Animal waste application equipment specified in the plan has been either field calibrated or evaluated in accordance
with existing design charts and tables and is able to apply waste, as necessary to accommodate the waste management
pian: (existing application equipment can cover the area required by the plan at rates not to exceed either the
specified hydraulic or nutrient loading rates, a schedule for timing of application has berg established; required buffers
can be maintained and calibration and adjustment guidance are contained as part of the plan) -
New, expanded or existing facility without existing waste SMlication emsinment, for spray irrigation (I)
Animal waste application equipment specified in the plan has been designed to apply waste as ne=mary to
%I matodatn the waste management plat:; (proposed application equipment can cover the area required by the plan at
rates not to exceed either the specified hydraulic or nutrient loading rates: a schedule for timing of applications has
been established; required buffers can be maintained; calibration and adjustment guidance are contained as part of the
per) •
() Newyexpanded•or existing facility without existing waste application amiQment for land Mgading not usin-g-may
irrigation. (WUPorl)
Aniutal waste application equipment specified in the plan has been selected to apply waste as necessary to
accommodate the waste management plan; (proposed gpplication equipment can cover the area required by the plan at
rases not to exceed either -the specified hydraulic or nutrient loading rates; a schedule for timing of applicaions has
been established: required buffers can be maintained; calibration and adjustment guidance are contained as part of the
plan).
Name of Technical Specialist (Please Print):
Affiliation:
Y w►.-S
Address(Agency)• .e`3 �e zss Phone No: z—z� titi
Si Date: 7 _ !S' 7 r7
E) Odor CAtrol. Insect
Con"l Mortality Management and Emggencv Action Plan WUP RC ar
Th waste mans
ent plan for this facility includes a Waste Management Odor Control Checklist, as Insect Control
a Mo
ty Management Checklist and an Emergency Action Plan. Sources of both odors and inserts have
evaluated w
respect to this site and Best Management Practices to Minimize_ Odors and Best Management
1
ces to OnInsects have been selected and tncltrded to the waste management plea. Both the Mortality
anan2ement Plan and the Emergency Action PIan are complete and can be implemented by this facility.
Name of Technical Specialist (Please Print): .\ 4s
Affiliation\a'w,
Address (Agency • D �-�-- Phone No.: ZBS�Ztt
Signature: Dater: i::
The allowg "gttature block is only to be used for new or expanding swine farms that begin construction after June
21 I946. Iinf a facility was built before June21, 1996, when was it constnreted or last expanded Mel I(we)
fy brat I( e) have attempted to contact by certified mail all adjoining property owners and all property owners
0 own pro located across a public road, street or highway from this new or expanding swine farm. The notice
was in comp cc with the requirements of NCGS 106405. A copy of the notice and a list of the property owners
notified is ed.
Name of Land Owner:
J Signature: Date: I
Name of Manager (if different from owner): i
I Signature: Date: I
AWC — January 1, 1997

:III_ Certifications -of 'on
A) Collection-ftaa ge. Treatment Installation
New, a ded or =fittad faciI' (SI)
Animal waste storage.and ttzatment structures such as but not limited to lagoons and ponds, have been installed in
accordance with the approved plan to meet or exceed the minimum standards and specifications.
,.%cC f rt,��''i
For adstjng facilities without x fits, no certification is necessary. ,.
Name of Technical Specialist (Please Print): , j. 4-6A L- TvuY-e!--V-, P
SUL
t�
Affiliation: _ _
wi 0. � w�•*-5 ZZ .
Addr=(Agency): -0 x -j" as< �i C_ .'hone No.: - �rg %`•�
Signature: 4 - Date: ?,-/131ri 7 +rrurr111f
B} Land Application Site (WOl)
Check the appropriate box
The cropping system is in place on all land as specified in the animal waste management plan.
() Conditional Approval: all required ]and as specified in the plan is cleared for planting; the cropping system -as
specified in the waste utilization plan has not been establisbed and the owner has committed to established the
vegetation as specified in the plan by (month/day/Year); the proposed cover crop is appropriate for
compliance with the waste utilization plan..
() Also chicle this box if appmpriaw
if the cropping system as specified in the plan can not be established on newly cleared land within 30 days of
this certification, the owner has committed to establish an interim crop for erosion control;
Name of Technical Specialist(Plmse Print):. W e5V.S \O e i
Address (Agency): .p v S� 1 Z�`{S�Phane No.: Z` Oq-ztLL.
Signature: Date: �r-1 '�
,--
This followi* signature block is only to be used wdm the box for conditional approval in = above has been checked.
I (we) that I (we)mi
ve comtted to establish the cropping system as specified in my (our) waste vtilirabion plan, and if
to establish the interim crop for erosion control, and will submit to DEM a verification of completion fi: a
Techni Specialist within 15 calendar days following the date specifed in the conditional ce rtifrcation. I (we) realize that
failure toy submit this verification is a violation of the waste management plan and will subject me (us) to an enforcement action
from DEM.
Name of Land Owner_
Signabire_ Date --
Name of Manger (if different from owner):
Signature: Datez
AWC — January 1. 1997 4

C7 Runoff Controigfrom FXkdor Lo (RC)
Facility with exterior lots
Methods to minimize the run off of pollutants from lounging and heavy use- areas have been instailedas specified in
the plan.
For facilities without exterior lots. no cerfirication is necessary.
Name of Technical Specialist (Please Print):
Affiliation:
Address(Agency): Phone No.:
Signature: Date:
D) Annfication and Handling Euuivinent Installation (WUP or 1)
O zea'r the aaprnpriate block
(� Animal waste application and handling equipment specified in the plan is on site and =dy for use; calibration and
adjus==t materials have beta provided to the owners and arc contained as part of the plan.
() Animal waste application and handling equipment specified in the plan has not been installed bathe owner has
proposed leasing or third party application and has provided a signed contract; equipment specified in the contract
agrees with the requirements of the plan; required buffers can be maintained, calibration and adjustment -guidance have
been provided to the owners and are contained as part of the plan.
() Conditional approval: Animal waste application and handling equipment specified in the plan has been purchased
and will be on site and installed by (month/daylyear); there is adequate storage to
hold the waste until the equipment is installed and until the waste can be land applied in accordance with cropping
system contained in the plan; and calibration and adjustment guidance have been provided to the owners and are
contained as Dart of the plan.
I Name of Technical Specialist (Please Print): Y( - 1. _ _ t.4 I
AfflIiation:tN
Address(Agency) nBor� �5 ?�.1� Z�ti Phone No.:
Signature: Date: <�7r 1 9 -7
The folio sig7(wel
b is only to be used When the boot for conditional approval in IHD above: has been checked.
1 (we) certify hav committed to purchase the animal waste application and handling equipment as specified in my
(our) waste plan and will submit to DEM a verification of delivery and installation from a Technical Specialist
within 15 eadarolio ' g the date specified in the conditional certification. I (we) realize that faiiuxe to submit ibis
verificatio is a vioof a waste management plan and will subied me (us) to an criforcernant action from DEM.
Name f Land Own
Sign Date:
Name of Nfanager(if different from owner):
Signature: Date:
E) Odor Control Insect Controi and Mortality Management SD SI RC or
Methods to cautrol odors and insects as specified in the Plan have bean installedand are operational. The mortality
manaeement system as specified in the Plan has also been installed and is overaational.
Name of Technical Specialist (Please Print):
Affiliation:
t
Address (Agency) t�, tt �� Z$` Phone No.: 2-IScL_2at
Signature:r_�== Date:
AwC -- Jadu . 1. 1997 5

:Please-re#urn-ithe-comoleted'fomL:to--.the-DI'LV-M*on 6EEnvironmentafTvLanagement
:at :the xoRowhxg-addregs:
-ntparbneatoLF
Division: OfFZMi3rGMnental' Mannp=Lent
Mater Quality -%=don, ComplimmeGroup
T. 0- B0IC29S5
'Raleigh, NC =626-OS35
PlemmaLso rmnanberto-st,hmi1FjLcw arthis- form along with- the rrmplet&AviaW Waste Af=kg=ent:PIzn to -the
local Soft -and -Water Conservation District Office and to keep.mcopy in your files -with -your A-b—I Wask-Maxmgement
FISIn
AWC — January 1, 1997 6

ML a SQL �uU , Lan ' 1
� P • ffi 1
L= b CYPRESS CREEK 14Y
`a `tIML
t ,m
u
4�
LL BFG COLLY
r
s Uffr ,w x
d
t+u 3
vy UM `
f
BIA108� ��
IL
U_
Lis
13
• Its L4
1!1!
I Lu
v ELRA►BEiHTOW�✓ 3
■713 +
fir STATE
FO
J $INGUTARY
E
y � ,
=p �
_ I
a Im XE
Singletary Lake State
Primarily used: for organ
camping. Singletary- lake
has one unit for 88 campe
mess hail and kitchen, camr
and wash houses. Twelve r
east of Elimbet mDwrr on Sta
53, the 1= acre lake- has
fishing-, boating- and hiking
campers.
9
r � �
1 ` ,o
l+17ND
�A, o
R •�

i - n::J�-����' `�:�F^ ' v:{:1�::�"}:.}'ii`.-.'.V:.��ti�:,n.:v:CWv,J
e
Producer: C r e c 5,5 Ce-e z k .Arse r
1
Location: S;�'19 Oil FA7� G� ! l R A .
Telephone: C9i b)Eq B - `-i
Type Operation: Zto r, - �e.e d e.,--
Number of Animals: g0p0
(Design Capacity)
AA ! F
GMel t a r•.� ) n! C. D, ?" i
The waste from your animal facility must be land applied at a specified rate to prevent
pollution of surface and/or groundwater. The plant nutrients in the animal waste should
be used to reduce the amount of commercial fertilizer required for the crops in the fields
where the waste is to be applied. This waste utilization -plan uses nitrogen as the limiting
nutrient. Waste should be analyzed before each application cycle. Annual soil tests are
strongly encouraged so that all plant nutrients can be balanced for realistic yields of the
crop to be grown.
Several factors are important in implementing your waste utilization plan in order to
maximize the fertilizer value of the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply more nitrogen'than the crop
can utilize. Soil types are important as they have different infiltration rates, leaching
potentials, cation exchange capacities, and available water holding capacities.. Normally
waste shall not be applied to land eroding at greater than 5 tons per acre per year. With
special precautions, waste may be applied to land eroding at up to 10 tons per acre per
year. Do not apply waste on saturated sons, when it is raining, or when the surface is
frozen. Either of these conditions may result in runoff to surface waters which is not
allowed under DEM regulations. Wind conditions should also be considered to avoid drift
and downwind odor problems. To maximize the value of nutrients for crop production
and to reduce the potential for pollution, the waste should be applied to a growing crop or
applied to bare ground not more than 30 days prior to planting. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on'typical nutrient content
for this type of facility. Acreage requirements should be based on the waste analysis
report from your waste management facility. Attached you will find information on
proper sampling techniques, preparation, and transfer of waste samples to the lab for
analysis.
This waste utilization plan, if carried out, meets the requirements for compliance with 1 5A
NCAC 2H.0217 adopted by the Environmental Management Commission.

Amount of Waste Produced Per Year(gallons ft3L tones etc.)
ICE animal s X Via( }a8rt f waste/animal/year = waste/year.
Amount of Plant Available Nitrogen (PAN) Produced Per Year
YCCQ &J3imals X.LLglbs. PAN/animal/year 300 lbs. PAN/year. (PAN from N. C. Tech.
Guide Std. 633)
Applying the above amount of waste is a big job. You should plan time and have
appropriate equipment to apply the waste in a timely manner_
The following acreage will be needed for waste application based on the crop to be grown
and surface application:
Table 1: ACRES OWNED BY PRODUCER
Tract Field Soil Crop Lbs. N Acres Lbs. N Month of
9 No Tvne Per Ac. * Utilized ADnlication
Total
* This N is from animal waste only. If nutrients from other sources such as commercial
fertilizer are applied, they must be accounted for. N must be based on realistic yield
expectation.
NOTE: The applicator is cautioned that P and .K maybe over applied while meeting the N
requirements. Beginning in 1996 the Coastal Zone Management Act will require farmers in
some eastern counties of North Carolina to have a nutrient management plan that addresses
allnutrients. This plan only addresses Nitrogen.
2

Table 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowner must be attached)
(Required only if operator does not own
adequate land [see Required Specification 21)
Traof Field Sod Crop Lbs. N Acres Lbs. N Month of
# No. Tvne Per Ac. * Utilized Anniication
* See footnote for Table 1.
Total .5 I -`' Y-�, - I
Totals from above Tables
Acres Lbs. N
Utilized
Table 1
Table 2
Total
Amount of N
Surplus o
5 b�
_ 56G
g.aa
5y5 0
Produced
ficit
31sy p
H010
NOTE: The Waste Utilization Plan must contain provisions far periodic land
application of sludge at agronomic rates. The sludge will be nutrient rich and will
require precautionary measures to prevent over application of nutrients or other
elements.
-.44.
ACIV.
3

.�iG: n""M,�'a?M1::..W`.'y'w.'M ��;.?�;TA:`'�:F
;^.w:.... ,,..k,JL:•;iT:-/..'v"~; .: I L .1, ?4 t ,..4.........
See attached nzap showing the fields to be used for the utilization of waste water.
Application of Waste by Irrigation
Field Soil Type Crop Application Application
No. Rate (Iu/Hr) Amount In.
THIS TABLE IS NOT M DED IF WASTE IS NOT BEING APPLIED BY IRRIGATION, HOWEVSk A SM AR TABLE WILT
BE QED FOR DRY UTTER OR SLURRY.
Your facility is designed for a SO days of temporary storage and the temporary storage
must be removed on the average of once every (, _ _—MONTHS. In no instance should
the volume of waste being stored in your structure exceed Elevation [ ChO-ff -,
Call the local.Natural Resources Conservation Service (formerly Soil: Conservation
Service) or Soil and Water Conservation District office after you receive the waste
analysis report for assistance in determining the amount per acre to apply and the proper
application rate prior to- applying the waste.
4

%~GILA
��^"h.M,-...w�,`�..�.`.�Q2�:'�a�"t:'��::L`rii2l'�'^•.w.,.:...`.'Y "'°'ri"-'�..�LYr.++•.�i3riii^ �":7.',�+'�:A.,.w,i:;.t".....,.v.:."'.v'.�,..,.m'.""'°+ww�.++.:�:t':-i.'�..`w.-....m....�..�:"�. w'�5,2:�:,:.-w'2``�.n, ':'F,:;,"�M.�""�"�
REQ=D SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff; drift, manmade
conveyances, direct application, or direct discharge during operation or land
application. Any discharge of waste which reaches surface water is prohibited. Illegal
discharges are subject to the assessment of civil penalties of $10,000 per day by the
Division of Environmental Management for every day the discharge continues_
2. The Field Office must have documentation in the design folder that the producer either
owns or has long term access to adequate land on which to properly apply the waste.
If the producer does not own adequate land to properly dispose of waste, he shall
provide NRCS with a copy of a written agreement (sample enclosed) with a landowner
who is v%rithin a reasonable proximity, allowing him/her the use of the land for waste
application for the life expectancy of the production facility. It is the responsibility of
the o«ner of the facility to secure an update of the Waste Utilization Plan when there
f is a change in the operation, increase in the number of animals, method of utilization,
or available land.
IAnimal waste shall be applied to meet, but not exceed, the Nitrogen needs for realistic
crop }Melds based on soil type, available moisture, historical data, climate conditions,.
and level of management, unless there are regulations that restrict the rate of
application for -other nutrients.
4. Animal waste may be applied to land that has a Resource Management System (RMS)
or an Alternative Conservation System (ACS).' If an ACS is used the soil loss shall be
no greater than 10 tons per acre per year and appropriate filter strips will be used
where runoff leaves the field. These filter strips will be in addition to 'Buffers"
required by DEM. [See FOTG Standard 393 -Filter Strips and Standard 390
(Interim) - Riparian Forest Buffers.]
5. , Odors can be reduced by injecting the waste or disking after waste application. Waste
should not be applied when the wind is blowing.
6. When animal waste is to be applied on acres subject to flooding, it will be soil
incorporated on conventionally tilled cropland. When applied to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not
occur during a -season prone to flooding. (See "Weather and Climate in North
Carolina" in the Technical Reference - Environment file for guidance.)

A"}.w. v`",.,'43'V."' w`;iY:i:. t Y `. wY - .�3 :'��T'`
�2..�w:.:µ:,'�`wvi.'n`�Svtw.-..iM /:.:}Si.JIR...YSs.:�{L::it...t
�.Sw%��Y."""v.:,:+J"%"'^`t"-».:.`.`�L:��.`,,.'•?.b:w.w�..:.tL�..n$`.0 "....;`��t:�Cwv^`..:,a: " �`Y`.�.....-......,..-::::ti,�S'
REQUIRED SPECIFICATIONS
(continued)
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
nmoffdoes not occur oifsite or to surface waters and in a method which does not
cause drift from the site during application. No'ponding should occur in order to
control conditions conducive to odor or flies and provide uniformity of application..
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when
the surface is frozen
9_ Animal waste shall be applied on actively growing crops in such a manner that no
mare .than 20 to 25 percent of the leaf area is covered.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste nutrient loading rates on these soils should
be held to a minimum and a suitable winter cover crop planted to take up.released
nutrients. - Waste shall not be applied more than 30 days prior to planting of the crop
on bare soil.
11. Animal waste shall not be applied closer than 25 feet to surface water_ This distance
may be reduced for waters that are not perennial provided adequate vegetative filter
strips are present. (See Standard 393 -Filter Strips)
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14. Waste shall be applied in a manner. not to reach other property and public right-of-
ways.
15. Animal waste shall not be discharged into surface waters, drainageways or wetlands by
a discharge or by over -spraying. Animal waste may be applied to prior converted
wetlands provided they have been approved as a land application site by a "technical
specialist". Animal waste should not be applied on grassed waterways that discharge
directly into water courses, and only then at agronomic rates provided the application
causes no runoff or drift from the site.

Cvvi: R+.^?.w Y:i:'.Y35' :.:5, T1-,. }S }i! 1 �:{A��'
v :�S:w. ?,'0" ..:-�-.'. , •f'' ^ ::Mtii`,-V.R..:+Li:.�:".RRJJrr�
�ww.."�L. :.N'.w......t.. w:.....r.: n.. �.x.�w.'.."w'.tvw�:��2i".:+":.L7'..".:'LS`..r+F
REQUIRED SPECIFICATIONS
(continued)
15. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc.,
shall not be discharged into the animal waste management system
r
17. Lagoons and other uncovered waste containment structures must maintain a maximum
operating level to provide adequate storage for a 25-year, 24-hour storm event in
addition to the one (1) foot mandatory freeboard.
18. A protective cover of appropriate vegetation be established on all disturbed areas
(lagoon embankments, bens, pipe runs, etc.). If needed, special vegetation shall be
provided for these areas and shall be fenced, as necessary, to protect the vegetation.
Vegetation such as trees, shrubs, and other woody species, etc. are limited to areas
where considered appropriate. Lagoon areas should be kept mowed and accessible_
Lagoon berms_and structures should be inspected regularly for evidence of erosion,
leakage, or discharge.
19. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
20. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, leaks, and spills. A regular maintenance checklist should
be kept on site.

Y.�N►:T I`ILI;nfJ
WASTE UTILIZATION PLAN AGREEMENT
Name of Farm: !La C�e.r
DwnerA,fanager Agreement
I (we) understand and will follow and implement the specification and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. I (we) know that any expansion to the existing design capacity of the
waste treatment and storage system or construction of new facilities will require a new
certification to be submitted to the Division of Environment Management (DEM) before
the new animals are stocked. I (we) also understand that there must be no discharge of
animal waste from this system to surface wasters of the state from a storm event less
severe than the 25-year, 24-hour storm- The approved plan A► 11 be filed on -site at the
farm office and at the office of the local Soil and Water Conservation District and will be
available for review by DEM upon request.
i
Name of Facility Owner:
(Please print)
Signature: Date: T _15 ` �I _
Name of M If different from owner): J o�, z L'
Signature: Date:
Name o echnical Spec' :(Please print)
Affiliation: „� �. ��•+�, , 4~�,r,,-�
Address (Agency): 3
4�
Rose- C 11 I 1NJC a- O Ll 6 D

..'.wS3P""Sr'.`.�`w,�"{...';ak�.�, ,h .•�A` ^^ Y `b ��'��:M�'�.Cc Y � " r �^^�^�J� Ain': n.,M �C u_`�,�"�^.�_`,t,�:x.;7:�,'..�x-.`fi.:k'r
A.NDV AL WASTE UTILIZATION AGREEMENT
(Needed only if additional land has to be leased, etc.)
L W--sklc —ga n l permission to
apply animal waste from his Waste Utilization S A4 on �(, _ acres of my land for
the duration of time shown below.
.-
I understand that this waste contains nitrogen, phosphorous, potas. ' im and other trace
elements and when properly applied should not ham my land or crops. I also understand
that the use of waste will reduce my need for commercial fertilizer.
Adjacent Landowner: Date: tz �t7
Waste Producer: 4��ate: a -!a "`T -7
Technical Representative - Date:
SWCD Representative) 1 Date:
Term of Agreement: - D ` I a , 19 97 to -1 a 2 20 D-?
(Minimum of Ten Years on Cost Shared Items)
(See Required Specification No. 2.)

System Calibration
Information presented in manufacturer's charts are based on average operation
conditions with relatively new equipment. Discharge rates and application rates
change over time as equipment gets older and components wear. In particular,
pump wear tends to reduce operating pressure and flow. With continued use,
nozzle wear results in an increase in the nozzle opening which will increase the
discharge rate while decreasing the wetted diameter.
You should be aware that operating the system differently than assumed in the
design will alter the application rate, diameter of coverage, and subsequently the
application uniformity. For example, operating the system with excessive pressure
results in smaller droplets, greater potential for drift, and- accelerates wear of the
sprinkler nozzle. Clogging of nozzles can result in pressure increase. Plugged
intakes or crystallization of mainlines will reduce operating pressure. Operating
below design pressure greatly reduces the coverage diameter and application
uniformity.
For the above reason, you should calibrate your equipment on a regular basis to
ensure proper application rates and uniformity. Calibration at least once every
three years is recommended. Calibration involves collecting and measuring flow at
several locations in the application area. Any number of containers can be used to
collect flow and determine the application rate. Rain gauges work best because
they already have a graduated scale from which to read the application amount
without having to perform additional calculations. However, pans, plastic buckets,
jars, or anything with a uniform opening and cross-section can be used provided
the liquid collected can be easily transferred to a scaled container for measuring.
For stationary sprinklers, collection containers should be located randomly
throughout the application area at several distances from sprinklers. For traveling
guns, sprinklers should be located along a transect perpendicular to the direction
of pull. Set out collection containers 25 feet apart along the transect on both
sides of the gun cart. You should compute the average application rate for all
nonuniformity of the application. On a windless day, variation between containers
of more than 30 percent is cause for concern. You should contact your irrigation
dealer or technical specialist for assistance.
`Reprinted for Certfcation Training for Operations of Animal waste Management Systems Manual

OPERATION & MAINTENANCE PLAN
Proper lagoon liquid management should be a year-round priority. It is especially
important to manage levels so that you do not have problems during extended rainy and
wet periods.
Maximum storage capacity should be available in the lagoon for periods when the
receiving crop is dormant (such as wintertime for bermudagrass) or when there are
extended rainy spells such as the thunderstorm season in the summertime. This means
.that at the first signs of plant growth in the later winter/early spring, irrigation according to
a farm waste management plan should be done whenever the land is dry enough to
receive lagoon liquid. This will make storage space available in the lagoon for future wet
periods. In the late summer/early fall the lagoon should be pumped down to the low
marker (set Figure 2-1) to allow for winter storage. - Every effort should be made to
maintain the lagoon close to the minimum liquid level as -long as the weather and waste
utilization plan will allow it.
Waiting until the lagoon has reached its maximum storage capacity before starting to
irrigate does not leave room for storing excess water during extended wet periods.
Overflow from the lagoon for any reason except a 25-year, 24-hour storm is a violation of
state law and subject to penalty action.
The routine maintenance of a lagoon involves the following:
Maintenance of a vegetative cover for the dam.
Fescue or common bermudagrass are the most common vegetative
covers. The vegetation should be fertilized each year, if -needed, to
maintain a vigorous stand. The amount of fertilizer applied should be
based on a soils test, but in the event that it is not practical to obtain
a soils test each year, the lagoon embankment and surrounding areas
should be fertilised with 800 pounds per acre of 10-10-10, or
equivalent.
Brush and trees on the embankment must be controlled. This may be
done by mowing, spraying, grazing, chopping, or a combination of
these practices. This should be done at least once a year and
possibly twice in years that weather conditions are favorable for
heavy vegetative growth.
NOTE: If vegetation is controlled by spraying, the herbicide must not be allowed to enter
the lagoon water. Such chemicals could harm the bacteria in the lagoon that are treating
the waste.
Maintenance inspections of the entire lagoon should be made during the initial filling of
the lagoon and at least monthly and after major rainfall and storm events. Items to be
checked should include, as a minimum, the following:
Waste Inlet Pipes, Recycling Pipes, and Overflow Pipes —look for:
1. separation of joints
2. cracks or breaks
3. accumulation of salts or minerals
4. overall condition of pipes

Lagoon surface —look for:
I. undesirable vegetative growth
2. floating or lodged debris
Embankment —look for:
I. settlement, cracking, or "jug" holes
2. side slope stability —slumps or bulges
3. wet or damp areas on the back slope
4. erosion due to lack of vegetation or as a result of wave action
5. rodent damage
Larger lagoons may be subject to liner damage due to wave action caused by strong
winds. These waves can erode the lagoon sidewalls, thereby weakcning the lagoon dart.
A good stand of vegetation will reduce the potential damage caused by wave action. If
wave action causes serious damage to a lagoon sidewall, baffles in the Jagoon may be
used to reduce the wave impacts.
Any of these features could lead to erosion and weakening of the dam: If your lagoon has
any of these features, you should call an appropriate expert famikiar with design and
construction of waste lagoons. You may need to provide a temporary -fix if there is a threat
of a waste discharge. However, a permanent solution should be reviewed by the
technical expert. Any digging into a lagoon dam with heavy equipment is a serious
undertaking with potentially serious consequences and should not be conducted unless
recommended by an appropriate technical expert_
Transfer Pumps --check for proper operation of:
I. recycling pumps
2. irrigation pumps
Check for leaks, loose fittings, and overall pump operation. An unusually loud or ganding
noise, or a large amount of vibration, may indicate that the pump is in need or repair or
replacement_
NOTE: Pumping systems should be inspected and operated. frequently enough so d= you -
are not completely "surprised" by equipment failure. You should perform your -pumping
system maintenance at a time when your lagoon is at its Iow level. This will allow some
safety time should major repairs be required. Having a nearly full lagoon is not.the time
to think about switching, repairing , or borrowing pumps. Probably, if your lagoon is full,
your neighbor's lagoon is full also. You should consider maintaining an inventory of spare
parts or pumps.
Surface water diversion features are designed to carry all surface
drainage waters (such as rainfall runoff, roof drainage, gutter outlets,
and parking lot runoff) away from your lagoon and other waste
treatment or storage structures. The only water that: should be
coming from your lagoon is that which comes from your flushing
(washing) system pipes and the rainfall that hits the lagoon directly.
You should inspect your diversion system for the following:
1. adequate vegetation
2. diversion capacity
3. ridge berm height

Identified problems should be corrected promptly. It is advisable to inspect your systi=
dung or immediately following a heavy rain. If technical assistance is needed to
deummine proper- solutions, consult with aPProPriam experts.
Youshould record the level of the lagoon just prior to when rain is predicted, and then
record the levei again 4 to 6 hours after the rain (assumes there is no pumping). This vnU
give you an idea of how ranch your lagoon level will rise with a certain rainfall amotmt
(you must also be recording your rainfall for ties to work). Knowing this should help in
Plante irrigation applications and storage. If your lagoon rises excessively, you may
have an inflow problem from a surface water diversion or there may be seepage i= the
lagoon from the surrounding land.
Iagooa Operation
Startup_
1. Immediately after construction establish a complete sod cover on bare soYi
surfaces to avoid erosion.
Z. Fill new lagoon design treatment volume at least half full of water before
waste loading begins, taking care not to erode lining or bank slopes_
3. Drainpipes into the lagoon should have a flexible pipe extender an the
end of the pipe to discharge near the bottom of the lagoon during initial
filling or another means of slowing the incoming water to avoid erosion of
the lining.
4. When possible, begin loading new lagoons in the spring to maximize
bacterial establishment (due to warmer weather).
5 _ It is recommended that a new lagoon be seeded with sludge from a healthy
working swine lagoon in the amount of 0.25 percent of the full_ lagoon
liquid volume. This seeding should occour-at least two weeks prior to the
addition of wastewater.
6. Maintain a periodic check on the lagoon liquid pH. If the pH falls below
7.0, add agricultural lime at the rate of i pound per 1000 cubic feet of
lagoon liquid volume until the pH rises above 7.0. Optimum lagoon Ezd&
pH is between 7.5 and 8.0.
7. A dark color, lack of bubbling, and excessive odor signals inadequate
biological activity. Consultation with a technical specialist is recommended
if these conditions occur for prolonged periods, especially during the warm
season.
The more frequently and reguiady that wastewater is added to a lagoon, the betterthe
lagoon will function_ Flush systems that wash waste into the lagoon several times daily are
optimum for aiz=ent Pit recharge systems, in which one or more buildings are drained.
and recharged each day, also work well_

Practice water conservation —minimize building water usage and
spillage from leaking-wate=s, broken pipes and washdown through
proper maintenance and water conservanon.
Minimise feed wastage and spillage: by keeping feeders adjusted. This
will reduce the amount of solids entering the Lagoon
Maintain lagoon liquid level between the permanent storage level and
the full temporary storage level.
Place visible marl= or stakes on the lagoon bank to show the
minimum liquid level and the maximum liquid. lever (Figure 2-1).
Start irrigating at the earliest possible daze in the spring based on
nutrient requirements and soil moismre so that 'temporary storage
will be maximized for the summer thunderstorm season. Similarly,
=gate in the late summer/early fall to provide nmmmum lagoon
storage for the warmer.
The lagoon liquid level should never be closer than 1 foot to the lowest
point of the dam or embankment.
Do not pump the lagoon liquid level lower that the permanent storage
level unless you are removing sludge.
Locate float pump intalaes approximately 18 inches underneath the liquid
surface and as far away from the drainpipe inlets as possible.
Prevent additions of bedding materials, long-stemmed forage
molded feed, plastic syringes, or other foreign mzterialc into the-lagoaa-
Frequently remove solids from catch basins at end of confinement houses.or
wherever they are installed.
Maintain strict vegetation, rodent, and varmint control near lagoon edges -
Do not allow trees or large bushes to grow on lagoon dam or embank nr.=
Remove sludge from the lagoon either when the sludge storage capacity is
full or before it fills 50 percent of the permanent storage volume.
If animal production is to be terminated, the owner is responsible for
obtaining and implementing a closure plan to eliminate the possibility of ar
pollutant discharge.
Sludge.Removah
Rate of lagoon sludge buildup can be reduced by:

proper lagoon s 2: ng,
mechanical solids separation of flushed waste,
gravity settling of flushed waste solids in an appropriately designed basin, or
minimiring feed wastage and spillage -
Lagoon sludge that is removed annually rather than stored long term will:
have more nutrients,
have more odor, and
require more land to properiy use the nutrients.
Removal techniques:
Hire a custom applicator.
Mix the sludge and lagoon liquid with a chopper -agitator impeller
pump through large -bore sprinkler irrigation system onto nearby cropland;
and soil incorporate_
Dewater the upper part of lagoon by irrigation onto nearby cropland or
forageland; mix remaining sludge; pump into liquid sludge applicator, haul
and spread onto cropland or foragelaud; and soil incorporate.
Dewater the upper part of lagoon by irrigation onto nearby cropland or
forageland; dredge sludge from lagoon with dxagrline or sludge barge; berm
an area beside lagoon to receive the sludge so that liquids can drain back -
into lagoon; allow sludge to dewater; haul and suread with manure spreader
onto cropland or forageiand; and soil incorporate.
R gardl= of the method, you must have the sludge material analyzed for waste
cow just as you would your lagoon water. The sludge will contain differ=t
nutrient and metal values from the liquid. The application of the sludge to fields will' be
limited by these nutrients as well as any previous waste applications to that field and crop
requirement- Waste application rates will be discussed in detail in Chapter 3.
When removing sludge, you Trust also pay attention to the liner to prevent damage- Close
attention by the pumper or drag -line operator will ensure that the lagoon liner remains
intact- If you see soil material or the synthetic liner material being disturbed, you should
stop the activity immediately and not resume until you are sure that the sludge can be
removed without liner injury- if the liner is damaged it must be repaired as soon as
possible -
Sludge removed from the lagoon has a much higher phosphorus and.heavy metal content
than liquid- Because of this it should probably be applied to land with low phosphorus
and metal levels. as indicated by a soil test, and incorporated to reduce the chance of
erosion- Note that if the sludge is applied to fields with very high soil -test phosphores, it
should- be applied only at rates equal to the crop removal of phosphorus_ As with other
wastes, always have your lagoon sludge analyzed for its nutrient value -
The application of sludge will increase the amount of odor at the waste application site
Extra Precaution ion should be used to observe the wind direction and other conditions which
could incase the concern of neighbors.

Possible Causes of Lagoon Faflnre
Lagoon faiimes -result in the unplanned discharge of wastervarer, from the structare. Z�pes
of failtz= include leakage through the bottom or sides, overtopping, and breach of the
darn- Assuming Proper design and construction, the owner has the responsibility for
eum=g structure safety. Items which may lead to lagoon fafiures include_
Modification of the lagoon struct im—an example is the placement of a pipe
in the dam without proper design and constracrian. (Consultan expert; is
lagoon design before placing any pipes in dams-)
Lagoon liquid levels --high levels.are. a safety risk-
Failure to inspect and maintain the dam_
Excess surface water flowing into the lagoon -
Liner integrity —protect from inlerpipe scouring, damage during sludge
removal, or rupture from lowering lagoon lied level below groundwater
table.
NOTE: If Igoon water is allowed to overtop the dam, the moving waterwill soon cause
gullies to form in the dam. Once this damage starts, it can quickly. cause a large discharge
of wastewater and possible dam failure.

EMERGENCY ACTION PLAN
PHONE NUMBERS
DIVISION OF WATER QUALITY (DWQ) III 9T6 ISM
EMERGENCY MANAGEMNE T SERVICES (EMS) 9 1 b 7b2 (r6
SOIL AND WATER CONSERVATION DISTRICT (SWCD) 5r v ba 693
NATURAL RESOURCES CONSERVATION SERVICE (NRCS) If/a SGa a 9 7Z
COOPERATIVE EXTERSION SERVICE (CES) s, `f ST I
This plan will be implemented in the event that wastes from your operation are leaking,
overflowing or running off site. You should not wain until wastes reach surface waters
or leave you property to consider that you have a problem. You should make every
effort to ensure that this does not happen. This plan should be posted in an accessible
location for air employees at the facility. The following are some action items you should
take.
7 . Stop the release of wastes. Depending on the situation, this may ore may nor be
possible. Suggested responses to some possible problems are listed belwo.
A. , - Lagoon overflow -possible solutions are:
a. Add soil to berm to increase elevation of dam.
b. Pump wastes to fields at an acceptable rate.
c. Stop all flows to the lagoon immediately.
d. Calla pumping contractor.
e. Make sure no surface water is entering lagoon.
B. Runoff from waste application field -actions include:
a. Immediately stop waste application.
b. Create a temporary diversion to contain waste.
c. Incorporate waste to reduce runoff.
d. Evaluate and eliminate the reason(s) that cause the runoff.
e. Evaluate the application rates for the fields where runoff occurred.
C. Leakage from the waste pipes and sprinklers -action include: .
a. Stop recycle pump.
b. Stop irrigation pump.
c. Close valves to eliminate further discharge.
d. Repair all leaks prior to restarting pumps.
❑. Leakage from flush systems, houses, solid separators -action include:
a. Stop recycle pump.
b. Stop irrigation pump.
c_ Make sure siphon occurs.
d_ Stop all flows in the house, flush systems, or solid separators.
1« Leakage from base or sidewall of lagoon. Often this is seepage as opposed
to Mowing teaks -possible action:
a. Dig a small sump or ditch from the embankment -to catch all
seepage, put in a submersible pump, and pump back to lagoon.
b. If holes are caused by burrowing animals, trap or remove animals and fill
holes and compact with a clay type soil.
c. Have a professional evaluate the condition of -the side walls -and- lagoon -
bottom as soon as possible.
1'

. 2. Assess the extent of the spill and note any obvious damages.
a. Did the waste• reach any surface waters?
b. Approximately how much was released and for what duration?
c. Any damage notes,_such as employee injury, fish kills, or property damage?
d. Did the spill leave the property?
e. Does the spill have the potential to reach surface waters?
f. Could a future rain event cause the spill to reach surface waters?
g. Are potable water wells in danger (either on or off the property)?
h. How much reached surface waters?
3. Contact appropriate agencies.
a. During normal business hours call your DWQ regional office; Phone - -. After
hours, emergency number. 919-733-3942. Your phone call should include: your
name, facility number, telephone number, the details of the incident from item 2
above, the exact location of the facility, the location or direction of movement of
the spill, weather and wind conditions. The corrective measures that -have been
under taken, and the seriousness of the sitution.
b. If spill leaves property or enters surface waters, call local EMS phone number.
c.- Instruct EMS to contact local Helath Department.
d. Contact CEs, phone number - , local SWCD office phone number - -, and local
NRCS office for advice/technical assistance phone number - -.
4. If none of the above works call 911 or the Sheriff's Department and explain you
problem to them and ask the person to contact the proper agencies Tor you.
S. Contact the contractor of your choice to begin repair or problem to minimize off -
site damage.
a. Contractors Name:
b. Contractors Address
c. Contractors Phone:
6. Contact the technical specialist who certified the lagoon (NRCS, Consufting
Engineer, etc.)
a. Name: /u�, I �L,ckr,r
b. Phone: -t 1 o �Vq aA L 1
7. Implement procedures as -advised by DWQ and technical assistance agencies to
rectify the damage, repair the system, and reassess she waste managment plan to
keep problems with release of wastes from happening again.
Z

INSECT CONTROL CHECKLIST FOR ANIMAL OPERATIONS
Source Cause 73MP's -to Minimize Odor Site Specific Practices
R - - (Liquid Systems$ --
Flush Gutters AccaumWation of solids 14'Rush system: is designed and operated
sufficiently to remove accumulated
from gutters as designed.
Remove bridging of acctunulatad solids at
discharge
Lagoons and Fft Cnu,Zed Solids { Maintain lagoons. settling basins and
pits where pest breeding is apparent to
minimizes the crusting of solids to a depth
of no more than 6-8 inches over more than
3Q% of surface -
Excessive Vegetative Decaying vegetation (f Maintain vegetative control along banks of
Growth lagoons and other impoundments to prevent
accumuiation of decaying vegetative matter
along water's edge on impoundment's peranster_
Feeders Feed Spillage
Feed Storage Accumulations of food residues
Animal Holding Areas Accumulauons of animal wastes
and feed wastage
NIC--November 11, 1996
(pry Systems)
[ 7 Design. operate and maintain feed systems (s.g_
bunkers and troughst to minimize the accumulation
of decaying wastage_
[) Clean up spillage on a routine basis (e.g. 7-10 day
interval during summer; 15-30 day interval during w
[) Reduce moisture accumulation within and around
irnmediate perimeter of feed storage areas by
insuring drainage away from site and/or provieft
adequate containment (e_g., covered bin for
brewer's grain and similar high moisture grain
products) -
Inspect for and remove or break up accumulated
solids in filter strips around feed storage as needed.
[) Eliminate low area that trap moisture along ferroas
and other locations where waste accumulates and
and disturbance by animals is n4nimal.
() Maintain fence rows and filter strips around anirrW
holding areas to minirreze accumulations of wastes
(i.a. inspect for and remove or break up accunwiated
solids as needed).

Dry Manure Handling Accumulations of anin, wastes () Rernove spillage on a routine basis (e.g. 7=I0 dell
Systems interval during.surrxnar; 1530 days imarvd during
winter} wftara numuL a is loaded for land application
or disposaf-
(I Provide for adequate drsnage around mamma mkpiee-
( ) Inspecr for and rnenavw or break up- aootun ismd Neertees
inAter stripes around stockpiles and manure hantift
grans as needed.
The issues checked ( ) pertain to iris operation. The landownerCntegrator agrees to use sound judgment in applying
insect control measures as practical.
I certify the aforementioned insect control beer Management Practices have been reviewed with roe.
(Landowner Signature)
For more infotnmdon comercr-the Cooperative 6ctension Service, Daparutrenr of EritomoloaY. Box 7613..North Caroline State University, Raleigh. NC
Z769S-7613.
AMIC—November 11, 1996

SWINE FARM WASTE MANAGEMENT ODOR CONTROL. CHECKLIST
Source Cause BMP's to Minimize Odor Site Spedfic Prac=ss
Farmstead Swine production (LIr V raw or wooded buffers;
( eccmmended bear management
and common sense
Anima( body surfaces Dirty manure-cavered ae:mals
Hoar surfaces Wet manure -covered floors I') 5WIted floors.
Wetarws located over slotted floors:
( +� arc at high end of salid floors;
( a manure buildup from Boom;
(} Underfloor ventilation for drying
Manure collection pits Urine ( ant manure removal by flush.pit
recharge.or scrape
Parital micarbial deco nposiaon (} Underfloor ventilation
Ventilation exhaust fans Volatile gases;
Dust U-Iff'icient air movement
Indoor surfaces Dust { Washdown between groups of animals
() Feed additives;
() Feeder covers;
(} Feed delivery downspout extenders to
feeder covers
Flush tanks Agitation of recycled lagoon { } Flush tank covers
liquid wf flas tanks are frilling (} Extend fill lines to near bottom of
ranks with ,anti -siphon vents
Flush alleys Agitation during wastewater ( ) Underfloor flush with underfloor
conveyanance ventilation
Pit recharge points Agitation of recycled lagoon ( ) Extend rechard lines to near bottom of
liquid while pits are filling pits with anti -siphon vents
Lift stations Agitation during sump tank filling () Sump ranic covers
end drewdown
Outside drain coUeetion Agitation during wastewater () Box covers
or junetion boxes conveyance
End of drainpipes at lagoon Agitation during wastewater () Extend discharge point of pipes
underneath lagoon liquid level
Lagoon surfaces Volatile gas emissions Gr roper lagoon liquid capacity
Biological mining '(►'i Correct lagoon startup procedures
Agitation () "nimum surface area-to-voiume ratio
(►j Minimum agitation when pumping
( ) Mechanical aeration
() Proven biological additives
rrigation sprinkle- no=es: High pressure agitation {y� gate on cry days with lithe or no wind
Wind draft (►4 4nimum recommended operation presSUre
(pump intake near lagoon iiquid surface-
( ) Pump from second -stage lagoon
.MOC—November 11. 1996

Storage tank or basin Perdad microbial de=rMosition ( ) Bottom or rnidlevei loading
surface Mixing white filling ( ) Tank covers
Agitation when emptying ( ) Basin surfaes mats of solids
( ) Proven biological additives or oxidants
Settling basin surface Partial rnicabiei decomposition (} Extend drainpipe outlets underneath liquid
Mixing while flung level
Agitation when emptying { } Remove settled sends regularly
Manure, slurry or sludge Agitation when spreading ( ) Soil injection of slurry/skrdges
spreader outlets Volatile gas annissions ( ) Wash residual manure fram spreader after use
( ) Proven bi*kM* d additives or oxidants
Uncovered manure, slurry Volatile gas emissions while drying ( } Soil infection of slurry/siudgas
or sludge on field surfaces () Soil ineorporudon wid n 48 hours
{ } Spread in thin uniform layers for rapid drying
{ } Prgvsn biologicai additives or oxidants
Dead animals
Carcass decomposition
Proper disposition of carcasses
Dead animaf disposal
Carcass decomposition
() Complete covering of carcasses in burial pits
pits
{ } Proper location/eonsavetion of disposal pits
Incinerators
Ineomplate combustion
() Secondary stack burners
Standing water around
Improper drainage
[ Grade and landscape such that water drains
facilities
Microbial decomposition of
away from facilities
organic matter
Manure tracked onto public
Poorty maintained access roads
( "Farm access road maintenance
roads from form access
Additional Inforn-radon: Available From:
Swine Manure Manegame= 0200 Rule/BMP Packet NCZ1J-Cw ayE tension canter
Swine Production Farm Potemial Odor Sources and Remedies, EBAE Fact Shear NCSU-aAE
Swine Production Facility Manure Management: Pit Recharge -Lagoon Treatment; EBAE i 28-88 NCSU-BAE
Swine Production Facility Manure Management-. Underfloor Huse -Lagoon Treatment. EBAE 129-88 NCSU-SAE
Lagoon Desig and Management for Livestock Manure Treatment and Storage; EBAE 103-83 NGSu4L4z
Calibration of Manure and Wastewater Application Equipment; EBAE Fact Sheet NCSU-BAE
;ontm[ling Odors from Swine Eked ngr. PIR-33 N{SUSwine Extension
°nvironmental Assunenc Program: NPPC Manual NC Park Produces Assoc
3ptions for Managing Odor: a report from the Swine Odor Task Force NCSU Agri C4mrunications
4uisence Concerns in Anie. Manure Management. Odors and Ries; PRO107. 19955 Conference Proceedings Florida Cooperative Extension
"he issues checked { } pertain to this operation. The landowner/integrator agrees to use sound judgment in applying
idor control measures as practical.
certify the aforernerrtioned odor control Best Managment Practices have been review with me_
(Landowno Signature)
AOC-November 11. 1996

MORTALITY MANACENTEUT METHODS
(check which method(s) are being implernented)
{ } Burial three feet beneath the surface of the ground within .24 hours
after knowledge of -the death. The burial be at least 300 feet from
any flowing steam or public body of water.
( Rendering at a rendering plant licensed under G. S. 106-168.7
{ ) Complete incineration
( } ` in the case of dead poultry only, placing in a disposal pit of a size and
design approved by the Department of Agriculture.
( ) Any method which in the professional opinion of the State
Veterinarian would make possible the salvage of part of a dead
animal's value without endangering human or animal health. (Written
approval of the Stare Veterinarian must be attached)

Grower: CYPRESS CREEK Designed By: CHB
Address: P.O. BOX 759 Checked By: JNT
ROSE HILL, NC 28458 Date: 1 03/11/97
County: BLADEN Sheet 1 of 7
ANAEROBIC WASTE LAGOON
DESIGN
FARM INFORMATION
Farm Population:
Nursery: --------------------
8000 Hd.
Finishing: ---------------------
0
Farrow to weanling:-------------------
0
Farrow to feeder: ---_-________-__--_-
0
Farrow to finish: --------------------
0
Boars: --------------------
0
Storage Period: - - - - - - - - - - - - - - - - -
- - 180 Days
25 Yr. / 24 Hr Storm Event - - - - - - - - - - - - - - - - -
- - 7.5 In:
"Heavy Rain" Factor Not Applicable
0.0
Rainfall in Excess of Evaporation - - - - - - - - - - - - - - - - -
- - 7.0 In.
Additional Water Usage: - - - - - - - - - - - - - - - - -
- - 0
Additional Drainage Area --------------------
0
LAGOON INFORMATION
Is Lagoon Designed as an Irregular Shape?
(Y/N) - - - - -- ----N
Does Operator Want Emergency Spillway?
(Y/N) - - - - - - - - - -N
Is This Design for an Existing Farm?
(Y/N) - - - - - - - - - -Y
Is Drain Tile Req'd to Lower SHWT?
(Y/N)-----------N
Seasonal High Water Table Elev:-----_---_-__---___
53.00 Ft
Freeboard: --------------------
1.0 Ft
Emergency Spillway Flow Depth: Not Applicable
Top of Storm / Spillway Buffer: Not Applicable
Side Slopes: - - - - -
- - - - - - - - - - - - - -
3 :1 (H:V)
Inside Top Length: -----.--------------
250.0 Ft
Inside Top Width: --------------------
230.0 Ft
Top of Dike Elevation: - - - - -
- - - - - - - - - - - - - -
59.00 Ft
Finished Bottom Elevation: - - - - --
- - - - - - - - - - - - -
49.00 Ft
Start Pump Elevation: - - - - -
- - - - - - - - - - - - - -
57.20 Ft
Stop Pump Elevation: -------------------
55.20 Ft
LAGOON VOLUME REQUIREDVOL DESIGN VOLUMES % REQ'D.
Storm Stor =
35938 (Cu.Ft.)
42,616 (Cu.FQ
118.58%
Temporary =
92151 (Cu.Ft)
99,484 (Cu.Ft.)
107.96%
Permanent =
240000 (Cu.Ft.)
244,882 Cu.Ft.)
10203%
Total Volume =
368,089 (Cu.Ft.)
386,982 (Cu.Ft.)
105.13%
Min. Required Liner Thickness - - - - - - - - - - - - - - - - - - -
Lagoon Surface Area: (InsideTOD)---________________
1.5 Ft
57,500 S. F.
Murphy Family Farms Engineering P.O. Box 759, Rose Hill NC 26458 (910) 289--2111

Grower. CYPRESS CREEK Designed By: CHB
Address: P.O. BOX 759 Checked By: JNT
ROSE HILL, NC 28458 Date: . 03/11/97
County: BLADEN Sheet 2 of 7
ACTUAL DESIGN VOLUME CALCULATIONS
LAGOON STAGE -AREA VOLUMES
Contour
Elevation (FT.)
Area SF
Incr. Vol. (Cu. FTC
Cumul._Vol. (Cu. FT)
49.00
32,300
50.00
34,496
33,398
33,398
51.00
36,764
35,630
69,028
52.00
39,104
37,934
106,962
53.00
41,516
40,310
147,272
54.00
44,000
42,758
190,030
55.00
46,556
45,278
235,308
56.00
49,184
47,870
283,178
57.00
51,884
50,534
333,712
58.00
54,656
53,270
386,982
59.00
57,500
56,078
443,060
These volumes were calculated using the vertical average end area method.
TOTAL REflD VOLUME:
368,089
CF
CUMULATIVE
VOL I ZONE VOL
105.13%
END PUMP = = = = >
55.20
FT
244,882 CF
TR'MT 244,882
102.03%
START PUMP = = = >
57.20
FT
344,366 CF
TEMP � 99,484
107.96%
MAX STORAGE = = >
58.00
FT
386,982 CF
STOW 42.616
118.58%
Murphy Family Farms Engineering
P.O. Box 759, Rose Hill NC 28458 (910)
289-2111

Grower: CYPRESS CREEK Designed By: CHB
Address: P.O. BOX 759 Checked By: JNT
ROSE HILL, NC 26458 Date: . 02/18/97
Countv: BLADEN Sheet 3 of 7
MINIMUM REC
Permanent Storage:
Required Treatment Volume:
[RED VOLUME CALCULATIONS
Animal T p e C aci * ALW cu.fl~ b = Total
Nursery
8,000
30
1.001
240,000
Finishing
0
135
1.001
0
Farrow to weanling
1 0
433
1.001
0
Farrow to feeder
0
522
1.00
0
Farrow to finish
01
1,4171
1.00
0
Boars
01
4001
1.00
0
Total Required
Treatment Volume
(cu. ft_)= 240.000
Sludge Storage Volume:
Animal Tvoe Capacitv * ALW * (cu.ft/Ib) = Totaill
Nursery
1 8,000
301
0.001
0
Finishing
0
1351
0.00
0
Farrow to weanling
0
4331
0.001
0
Farrow to feeder
0
522
0.00
0
Farrow to finish
01
1,417
0.00
0
Boars
0
00 4
0.000
0
Total Required Sludge Storage Volume (cu. ft.) = 0
Temporary Storage Volume:
Manure Production:
lAnimal Type Capacity * Sto. Period * (gals/Hd./day)= ota
Nursery
8,000
180
0.30
438.400
Finishing
0
180
1.371
0
Farrow to weanlin
0
180
4.39
0
Farrow to feeder
0
180i
5.30
0
Farrow to finish
01
1801
14.38
0
Boars
01
1801
4.061
0
Total Manure Production (gals.)= 438,400
Total Manure Production (cu.ft.)= 58,610
Excess Fresh Water:
Animal Type Capacitv * Sto. Period * als Hd. da = Total
Nurseg
8,000
180
0.00
0
Finishing
0
1801
0.00
0
Farrow to weanling
0
180
0.00
0
Farrow to feeder
01
180
0.00
0
Farrow to finish
01
180
0.00
0
Boars
01
180
0.00
0
i otai rresn water txcess (gals.) =
Total Fresh Water Excess (cu.ft.)
Murphy Family Farms Engineering P.O. Box 759, Rose Hill NC 28458 [phone]

Grower. CYPRESS CREEK Designed By: CHB
Address: P.O. BOX 759 Checked By: JNT
ROSE HILL, NC 28458 Date: 1 02/18/97
Countv: BLADEN Sheet 4 of 7
Temporary Storage Volume: (Cont.
Rainfall in Excess of Evaporation:
Vol. =(Lagoon Surface Area + Additional Drainage Area) * Rainfall / 12in./ft
Vol.= (57500 sq.fL + 0 sq.fL) * 7 in. /12 in./ft.
Total Required Volume for Rainfall in Excess of Evap. (cu.ft.) = 33,542
Storm Storage:
Vol. = (Lagoon Surf. Area + Addt`l Drainage Area) * 25Yr./24Hr. Storm (in) / 12in./fL
Vol. = (57500 sq.ft + 0 sq.ft) * 7.5 in. 112 in./ft.
Total Required Volume for 25W.-241-1r. Storm Event (cu.ft)= 35,938
'Heavy Rain" Storage:
Vol.=(Lagoon Surf. Area + Addfl Drainage Area) * "Heavy Rain" Factor (in) / 12in./ft
Vol. = (57500 sq.ft + 0 sq.ft.) * 0.0 in. /12 in./ft.
Total Required Volume for'Heavy Rain' (cu.ft.) = 0
(for Extended Periods of Chronic Rainfall)
Additional Water Storage:
No Additional Water Storage is Required
Total Required Storm Storage
(25 Yr. / 24 Hr. Storm + "Heavy Rainj = 35,938 (CU.FT)
Total Required Temporary Storage
(Manure Prod. + Excess Fr. Water + Rainfall Excess) = 92,151 (CU.FT)
Total Required Permanent Storage
(Treatment + Sludge) = 240,000 (CU.FT)
TOTAL REQUIRED VOLUME= 368089 (CU.FT.)
Murphy Family Farms Engineering P.O. Box 759, Rose Hill NC 25456 (97U) 2d9-217 7

Address: P.O. BOX 759
ROSE HILL, NC 28458
County: BLADEN
LAGOON DESIGN SUMMARY
Checked By: JNT
Date: 02/18/97
Sheet 5 of 7
Top of Dike Elevation -------------------
Emergency Spillway Crest Elevation -------------------
Top of 25 yr/24 hr Storm Storage -------------------
Top of "Heavy Rain'Storage --------------------
Start Pump Elevation -------------------
End Pump Elevation ---------------------
Top of Sludge Storage -------------------
Seasonal High-Watertable Elev. --------------------
Finished Bottom Elevation -----------_--------
Inside Top Length --------------------
Inside Top Width -------------------
Side Slopes -------------------
Lagoon Surface Area -------------------
Min. Liner Thickness (if required) -------------------
Freeboard Depth -------------------
Temporary Storage Period - - - - - - - - - - - - - - - - - - -
Zone Depths:
59.00 FT.
Not Applicable
58.00 FT.
Not Applicable
57.20 FT.
55.20 FT.
Not Applicable
52.50 FT.
49.00 FT.
250.00 FT.
230.00 FT.
3:1 HN
57,500 SF
1.5 FT.
1.00 FT.
180 Days
TOTAL DESIGN VOLUME = 386982 (CU.FT.)
Treatment / Sludge Storage Zone Depth -- - - - - - - - - - - 6.2 FT.
Temporary Storage Zone Depth - - -- -- - - - - - - - 2.0 FT.
Freeboard / Storm Storage Zone Depth - - - - - - - - - -- 1.8 FT.
Total Lagoon Depth -- - - - - - - - - - - 10.0 FT.
Murphy Family Farms Engineerkg P.O. Box 759, Rose Hill NC 26458 [phone]

Grower:
Address:
A
P.O. BOX 759
ROSE HILL, NC 28458
BLADEN
ZONE ELEVATIONS
Designed y: H
Checked By: JNT
Date: 02/18/97
Sheet 6 of 7
TOP OF DIKE ELEV = 59.00
1 1 I 1
/ 1 TOP OF STORM ELEV = 58.00 / 1
1 l
1 /
STRT PMP EL.= 57.20 1 TOP OF TEMP STORAGE ELEV = 57.20 /
1 1
END PMP EL. = 55.20 1 TOP OF TREAT ELEV = 55.20 SHWT = 52.50
1 l
1 /
1 /
1 ! '
FINISHED BOTTOM ELEV = 49.00
Murphy Family Farms Engineering P.U. Box 759, Rose Nil! NG 20458 [phone]

Address: P.O. BOX 759
ROSE HILL, NC 28458
Checked By: JNT
Date: 02/18/97
of 7
This livestock waste treatment lagoon is designed in accordance with the North Carolina
Natural Resources Conservation Service PRACTICE STANDARD 359— WASTE TREATMENT
LAGOON, revised prior to June, 1996. -
Emergency Spillway:
An Emergency Spillway is not required.
NOTE: See attached Waste Utilization Plan %0tit"111++++,,,
DESIGNED:
- a�.Scnt -�f
DATE: 31i-6f 47 - 14935
nisS
COMMENTS:
Murphy Family Farms Engineemg P. D. Box 759, Rose Hill NC 28458 [phone]

ADDRESS: P.O. BOX 759 CHECKED BY: JNT
ROSE HILL, NC 28458 DATE: . 02118/97
COUNTY: BLADEN SHEET 1 OF 2
OPERATION AND MAINTENANCE PLAN
This lagoon is designed for waste treatment (permanent storage) and 180 days of
temporary storage. The time required for the planned fluid level (permanent and
temporary storage) to be reached may vary due to site conditions, weather, flushing
operations, and the amount of fresh water added to the system.
The designed temporary storage consists of 180 days of temporary storage for:
(1) manure production of animals, (2) excess fresh water storage, (3) rainfall in
excess of evaporation, (4) storage for the 25 year J 24 hour storm for the location,
(5) and, it applicable, an additional °heavy rain" storage volume for chronic rainfall
events. Allocation for any additional fresh water usage is also included in the
temporary storage. The volume of waste generated from a given number of animals
will be fairly constant throughout the year, but excess rainfall will vary from year to year.
The 25 year rainfall will not be a factor to consider in an annual pumping cycle, but
this storage volume must always be available.
A staff gauge must be installed in the lagoon that indicates the start pumping and stop
pumping levels. The start pumping level is the maxium liquid level under normal operating
conditions. The stop pumping level is the minimum liquid level under normal
operation to maintain required treatment volume and depth. Pumping can be started
and stopped anywhere between these two elevations for operating convenience as site
conditions permit, such as weather, soils, crop, and equipment in order to apply waste
without runoff or leaching. However, it is recommended that the lagoon be kept
pumped down as much as possible.
Land application of wastewater is recognized as an acceptable method of disposal.
Methods of application include solid set, center pivot, guns, and traveling guns. Care
should be taken when applying waste to prevent damage to crops.
The following items are to be carried out:
1. It is required that the treatment lagoon be precharged to one --half the treatent volume
or as otherwise specified on the lagoon design drawings before wastes are introduced.
The purpose is to prevent excessive odors during start—up. Precharging reduces the
concentration of the initial waste entering the lagoon thereby reducing odors. Solids should
be covered with effluent at all times. When precharging is complete, flush buildings with
recycled lagoon liquid. Fresh water should not be used for flushing after initial filling.
2. The attached Waste Utilization Plan shall be followed. The plan recommends
sampling and testing of waste before land application.
Murphy Family Farms Engineering P.O. Box 759, Rose Hill NC 28458 [phone]

ADDRESS: P.O. BOX 759
ROSE HILL, NC 28458
COUNTY: BLADEN
CHECKED BY: ,fNT
DATE: . 02/18/97
SHEET 2 OF 2
3. Begin temporary storage pump —out of the lagoon when the fluid level reaches the
elevation 57.20 as marked by the staff gauge. Stop pump —out when thefluid level
reaches elevation 55.20. This temporary storage, less 25 year / 24 hour storm,
contains 99484 cubic feet or 744140 gallons.
4. The recommended maximum amount to apply per irrigation is one (1) inch and the
recommended maximum application rate is 0.3 inches per hour. Refer to the waste
utilization plan for further details.
5. Keep vegetation on the embankment and areas adjacent to the lagoon mowed
annually. Vegetation should be fertilized as needed to maintain a vigorous stand.
6. Repair any eroded or damaged areas and establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable outsets.
8. Keep a minimum of 25 feet of grass vegetated buffer around waste utilization
fields adjacent to perennial streams. Waste will not be applied in open ditches.
Do not pump within 200 feet of a residence or within 100 feet of a well. Waste shall
be applied in a manner such that waste will not reach other property and public
rights —of ---way.
9. The Clean Water Act of 1977 prohibits the discharge of pollutants into waters
of the United States. Waste shall not be discharged into surface waters, drainageways,
or wetlands by either discharge or by over —spraying. The Department of Environment,
Health, and Natural Resources, Division of Environmental Management,
has the responsibility for enforcing this law.
Murphy Family Farms Engineemg P. 0. Box 759, Rose Hill NC 28456 (910) 2a9-2111

GROWER: CYPRESS CREEK DESIGNED BY: CHB
ADDRESS: P.O. BOX 759 CHECKED BY: JNT
ROSE HILL, NC 28458 DATE: 02/18/97
COUNTY: SLADEN SHEET 1 OF 3
SPECIFICATIONS FOR CONSTRUCTION OF WASTE TREATMENT LAGOONS
FOUNDATION PREPARATION:
The foundation area of the lagoon embankment and building pad shall be cleared of
trees, logs, stumps, roots, brush, boulders, sod, and rubbish. Satisfactory disposition
will be made of all debris. The topsoil from the lagoon and pad area should be stripped
and stockpiled for use on the dike and pad areas. After stripping, the foundation area
of the lagoon embankment and building pad shall be thoroughly loosened prior to placing
the first lift of fill material to get a good bond.
EXCAVATION AND EARTHFILL PLACEMENT
The completed excavation and earthfill shall conform to the lines, grades, and elevations
shown on the plans. Earthfill material shall be free of material such as sod, roots, frozen
soil, stones over fi inches in diameter, and other objectionable material. To the extent they
are suitable, excavated material may be used as fill. The fill shall be brought up in
approximately horizontal layers not to exceed 9 inches in thickness when loose and prior
to compaction. Each layer will be compacted by complete coverage with the hauling and
spreading equipment or standard tamping roller or equivalent method. Compaction will
be considered adequate when fill material is observed to consolidate to the point that
settlement is not readily detectable. NOTE THE SPECIAL REQUIREMENTS FOR
PLACEMENT OF LINERS IN THE LINER SECTION OF THIS SPECIFICATION.
The embankment of the lagoon shall be installed using the more impervious materials from
the required excavations. Construction of fill heights shall include 5 percent for settlement.
Dikes over 15 feet in height with an impoundment capacity of 10 acre—feet or more fall
under the jurisdiction of the NC Dam Safety Law and require permitting by the NC Dept of
Environment, Health and Natural Resources, Land Quality Section. The height is defined
as the difference in elevation from the constructed height to the downstream toe of the dike.
Precautions shall be taken during construction to prevent excessive erosion and
sedimentation.
LINER:
THE MINIMUM REQUIRED CLAY LINER THICKNESS SHALL BE 1.5 FT.
NOTE: LINERS (PARTIAL OR FULL) ARE REQUIRED WHEN INDICATED ON THE
DRAWINGS OR WHEN MATERIAL IS ENCOUNTERED DURING CONSTRUCTION THAT
WILL NOT PROVIDE THE PERMEABILITY LIMITS AS STATED LATER IN THIS SECTION.
SUCH MATERIAL IS CONSIDERED UNSUITABLE WITH RESPECT TO LINING. ATYPICAL
CROSS SECTION OF THE LINER IS INCLUDED IN THE DRAWINGS WHEN LINERS
ARE REQUIRED.
Murphy Family Farms Engineering P.O. Box 759, Rose Hill NC 28456 [phone]

GROWER: CYPRESS CREEK DESIGNED BY: CHB
ADDRESS: P.O. BOX 759 CHECKED BY: JNT
ROSE HILL., NC 28458 DATE: 1 02/18/97
COUNTY: BLADEN SHEET 2 OF 3
When areas of unsuitable material are encountered, they will be overexcavated below
finish grade to the specified depth as measured perpendicular to the finish grade. The
foundation shall be backfiiled as specified to grade with a material approved by the
engineer or his representative.
REFER TO THE DRAWINGS FOR SPECIAL CONSIDERATIONS.
Soil liner material shall come from an approved borrow area. The minimum moisture
content of the liner material shall be optimum moisture content which relates to that
moisture content when the soil is kneaded in the hand it will form a ball which does not
readily separate. Water shall be added to borrow as necessary to insure proper moisture
content during placement of the Iiner. The moisture content of the liner material shall not
be less than optimum moisture content during placement The maximum moisture
content relates to the soil material being too wet for efficient use of hauling equipment and
proper compaction. Proper compaction of the liner includes placement in 9 inch lifts and
compacted to at least 95 percent of the Standard Proctor Maximum Dry Density
(ASTM D698) of the liner material. When smooth or hard, the previous lift shall be scarified
and moistened as needed before placement of the next lift.
The single most important factor affecting the overall compacted permeability of a clay
liner, other than the type of clay used for the liner, is the efficient construction processing
of the compacted liner. The sequence of equipment in an established pattern helps
assure uniformity in the entire placement and compaction process. For most clay soils, a
tamping or sheepsfoot roller is the preferred type of compaction equipment
In accordance with NRCS South National Technical Center (SNTC) Technical Note 716
(revised September 1993) the maximum allowable specific discharge of the liner is
1.0 x 10-5 cm/sec. This specific discharge is dependant on the permeability of the
liner material, the liner thickness, and the hydrostatic pressure on the liner. With the
minimum required liner thickness stated earlier and the maximum liquid depth in the
lagoon, the maximum permeability of the compacted liner is 1.25 x 10-6cm/sec. Upon
completion of the liner, undisturbed samples will be taken and tested for actual
permeability. Any permeability tests indicating a higher permeability than stated above
will be considered as failing. Failing tests will require recompaction of the liner material
and retesting.
For lagoons being built in soils which do not require clay lining the same permeability
requirements apply as for clay liners and testing of the in —situ material will be conducted.
During the excavation process, soils at the excavated surface are loosened as adjacent
material is being removed. As a result, the permeability of these surface soils is increased.
To insure proper compaction and minimum soil permeability, when lagoon excavation is
complete the inner side slopes and bottom shall be roiled thoroughly prior to testing.
Murphy Family Farms Engineering P.O. Box 759, Rose Hill NC 28458 [phone]

GROWER: CYPRESS CHEEK DESIGNED BY: CHB
ADDRESS: P.O. BOX 759 CHECKED BY: JNT
ROSE HILL, NC 28458 DATE: 02/18/97
COUNTY: BLADEN SHEET 3 OF 3
The soil liner shall be protected from scour produced by the discharge from waste outlet
pipes. This can be done by using some type of energy dissipator: concrete flumes,
concrete blocks laid tightly together, or using flexible pipe outlets on waste pipes.
Alternatives to soil liners are synthetic liners and bentonite sealant. When these are
specified, additional construction specifications are included with this Construction
Specification or are shown on the drawings.
CUTOFF TRENCH:
A cutoff trench shall be constructed under the embankment area when called for in the
notes on the drawings or as shown on a typical cross section on the drawings. The finial
dimensions of the cutoff trench shall be determined by observation of the foundation
materials during construction.
VEGETATION:
All exposed embankment and other bare constructed areas shall be seeded to the
planned type of vegetation as soon as possible after construction according to the
seeding specifications. Topsoil, if available on site should be placed on areas of the dike
and pad to be seeded. Temporary seeding or mulch shall be used if recommended
permanent vegetation is out of season dates for seeding. Permanent vegetation should
be established as soon as possible during the next period of approved seeding dates.
REMOVAL OF EXISTING TILE DRAINS:
An observation trench shall be dug along the perimeter of the lagoon 25 feet outside the
proposed embankment toe to verify that no subsurface drain file lines are present in the
lagoon area The trench shall be dug to a minimum depth of five feet and shall have a width
adequate to accommodate equipment used for backfill and compaction. Trench side
slopes shall be 1:1 or flatter. Trench backfill shall be compacted as stated in the
EXCAVATION AND EARTHFILL PLACEMENT section of the specification.
When the drains are encountered, the file will be removed to a minimum of 25 feet beyond
the outside toe.of slope of the dike. The file trench shall be backfilled and compacted with
material approved by the engineer or his representative. Tile drains that are removed
shall be either capped off or rerouted around the lagoon, as directed by the engineer or
his representative.
SAFETY AND HEALTH REQUIREMENTS:
All operations shall be carried out in a safe, skillful, and workmanlike manner. All safety and
health regulations shall be observed and appropriate personal safety and health measures
used at all times during construction.
Murphy Family Farms Engineering P.O. Box 759, Rosa Hill NC 28458 [phone]

ADDRESS: P.O. BOX 759 CHECKED BY:
ROSE HILL, NC 28458 DATE:
COUNTY: BLADEN SHEET 1
SEEDING SPECIFICATIONS
ACREAGE TO BE SEEDED: 2.0 ACRES
USE THE SEED MIXTURE INDICATED AS FOLLOWS:
120 LBS. FESCUE GRASS AT 60 LBS./ACRE
(BEST SUITED ON CLAYEY OR WET SOIL CONDITIONS)
SEEDING DATES: SEPTEMBER 1 TO NOVEMBER 30
FEBRUARY 1 TO MARCH 30
JNT
02/18/97
OF
60 LBS. RYE GRAIN AT 30 LBS./ACRE (NURSERY FOR FESCUE)
120 LBS. 'PENSACOLA' BAHIA GRASS AT 60 LBS./ACRE
(SEE FOOTNOTE NUMBER 1)
SEEDING DATES: MARCH 15 TO JUNE 15
16 LBS. HULLED COMMON BERMUDA GRASS AT 8 LBS./ACRE
(SUITED FOR MOST SOIL CONDITIONS)
SEEDING DATES: APRIL 1 TO JULY 31
20 LBS. UNHULLED COMMON BERMUDA GRASS AT 10 LBS./ACRE
SEEDING DATES: JANUARY 1 TO MARCH 30
80 LBS. RYE GRASS AT 40 LBS./ACRE (TEMPORARY VEGETATION)
SEEDING DATES: DECEMBER 1 TO MARCH 30
APPLY THE FOLLOWING:
2000 LBS. OF 10-10--10 FERTILIZER (1000 LBS./ACRE)
4 TONS OF DOLOMITIC LIME (2 TONS/ACRE)
200 BALES OF SMALL GRAIN STRAW (100 BALES/ACRE)
ALL SURFACE DRAINS SHOULD BE INSTALLED PRIOR TO SEEDING. SHAPE ALL
DISTURBED AREAS IMMEDIATELY AFTER EARTH MOVING IS COMPLETED.
APPLY LIME AND FERTILIZER THEN DISK TO PREPARE A 3 TO 4 INCH SMOOTH
SEEDBED. APPLY SEED ANDFIRM SEEDBED WITH A CULTIPACKER OR SIMILAR
DEVICE. APPLY MUCH AND SECURE WITH AN ANCHORING TOOL OR NETTING.
1. PENSACOLA BAHIA GRASS IS SLOWER TO ESTABLISH THAN COMMON
BERMUDA GRASS. WHEN USING BAHIA, IT IS RECOMMENDED THAT 8
LBS_/ACRE OF COMMON BERMUDA BE INCLUDED TO PROVIDE COVER UNTIL
BAHIA GRASS IS ESTBLISHED.
Murphy Family Farms Engineerv7g P.O. Box 759, Rose Hill NC 28458 [phone]

GROWER: CYPRESS CREEK
ADDRESS: P.O. BOX 759
ROSE HILL, NC 28458
COUNTY: B
Emergency Action Plan
CHECKED BY:
DATE:
SHEET
JNT
02/18/97
OF 2
Using this outline as guidance; you should develop a specific emergency action plan for your
waste handling system.. This plan will be implemented in the event that wastes from your
operation are leaking, overflowing, or running off the site. You should NOT wait until wastes
reach surface water or leave your property to consider that you have a problem. You should
make every effort to ensure that this does not happen. This plan should be available to all
employees at the facility, as accidents, leaks, and breaks could happen at any time. Your
plan should follow this format:
1. Stop the release of wastes. Depending on the situation, this may or may not be
possible. Suggested responses to problems are listed below:
A. Lagoon overflow —possible solutions are:
add soil to berm to temporarily increase elevation of dam —any permanent
alteration of the dam should be approved by a qualified professional engineer
or qualified technical specialist
pump wastes to field at an acceptable rate
stop all additional flow to the lagoon (waters) -- —hold waste in house if possible
call a pumping contractor
make sure no surface water is entering lagoon
NOTE: The above listed activities should be started when your lagoon level has exceeded
the temporary storage level.
B. Runoff from waste application field —actions include:
immediately stop waste application
create a temporary diversion or berm to contain the waste on the field
incorporate waste to reduce further runoff
C. Leakage from the waste distribution system:
pipes and sprinklers —actions include:
stop recycle (flushing system) pump
stop irrigation pump
close valves to eliminate further discharge
separate pipes to create an air gap and stop flow
flush system, houses, solids separators —actions include:
— stop recycle (flushing system) pump
— stop irrigation pump
— make sure no siphon effect has been created
— separate pipes to create an air gap and stop flow
D. Leakage from base or sidewall of lagoon. Often these are seepage as opposed to
flowing leaks —possible action*:
dig a small well or ditch to catchall seepage, put in a submersible
pump, and pump back into lagoon
if holes are caused by burrowing animals, trap or remove animals and
fill holes and compact with a clayey soil
other holes may be likewise temporadly plugged with clay soil
Murphy Family Farms Engineering P.O. Box 759, Rose Hill NC 28458 [phone]

UHUVVtH: L:YHHt55 UHttK DESIGNED BY: C:Hb
ADDRESS: P.O. BOX 759 CHECKED BY: JNT
ROSE HILL, NC 28458 DATE: 02/18/97
COUNTY: BLADEN SHEET 2 OF 2
*Lagoon problems require the consultation of an individual experienced in the
design and construction of lagoons for permanent repair measures.
2. Assess the extent of the spill and note any obvious damages.
A. Did the waste reach any surface water?
B. Approximately how much was released and for what duration?
C. Any damage noted, such as employee injury, fish kills,. or property damage?
3. Contact appropriate agencies.
B. During noral business hours,. call your DE regional office, at 919-486-1541
after hours, emergency number: 910-733-3942. Your phone call should
include: your name, facility, telephone number, the details of incident from
item 2 above, the exact location of the facility, and the location or direction
of movement of the spill, weather and wind conditions, what corrective
measures have been under taken, and the seriousness of the situation.
C. If spill leaves, or is likely to leave, property or enters surface waters, call
local emergency management service (EMS)at 910-862-6760.
D. Instruct EMS to contact local Health Department.
E. Contact local Soil and Water Conservation District Natural Resources Conservation
Service office at 910-562-6936 for advice/technical assistance.
910-862-4591 for advice/technical assistance.
A. Contact Murphy family Farms Land and Nutrient Manageent Departent at 910-
289-2111 for advice/technical assistance.
4. Implement procedures as advised by DEM and technical assistance agencies to rectify
the damage, repair the system, and reassess the waste management plan to keep
problems with release of wastes from happening again.
BLADEN COUNTY COOPERATIVE EXTENSION SERVICE
PO BOX 248, ELIZABETHTOWN, NC 28337
910-862-4591
BLADEN COUNTY SOIL AND WATER CONSERVATION DISTRICT
ROOM 122 AGRICULTURAL SERVICE CENTER
ICE PLANT RD, ELIZABETHTOWN, NC 28337 — 9409
910— 862— 6936
BLADEN COUNTY EMERGENCY MANAGEMENT SYSTEM
PO BOX 1635, ELIZABETHTOWN, NC 28337
910— 862— 6760
DIVISION OF ENVIRONMENTAL MANAGEMENT
WACHOVIA BUILDING SUITE 714
FAYETTEILLE, NC 28301---5043
919— 486-1541
Murphy Family Farms Engineering P.O. Box 759, Rose Hill NC 28458 [phone]

1
Source Cause BMPs to MlnlmI7AOdor Site Specific Practices
Standing water around a Improper drainage; Qrado and landscape such that water drains
facilities • Microbial decomposition of away from facilities
organic matter
Manure tracked onto Poorly maintained access roads Fans access road maintenance
public roads From farm
access
4
Additional Information: Available From
Swine Manure Management ; 0200 RulcfBMP Packet NCSU, County Extension Center
'Swine Production Farm Potential Odor Sources and Remedies ; EBAE Fact Sheet NCSU - BAE
Swine Production Facility Manure Management: Pit Rec} arge - Lagoon Treatment; EBAB 128.88 NCSU - BAE
Swine Production Facility Manure Management: Underfloor Flush - Lagoon Treatment; EBAE 129-88 NCSU - BAE
Lagoon Dcslgn and Management for Livestock Manure Treatment and Storage; EBAI3 103.83 NCSU - BAE
Calibration of Manure and Wastewater Application Equipment ; EBAR Fact Sheet NCSU - BAE
Controlling Odors from Swine Buildings; PIH-33 NCSU - Swine Extension
Environmental Assu•ru.ce Program ; NPPC Manuel NC Pork Producers Assoc
Options for Managing Odor; a report from the Swine Odor Task Force NCSU Agri Communicatibns
Nuisance Concerns In Animal Manure Management: Odors and Files; PRO107, 1995 Conference Proceedings Florida Cooperative Extension
AMOC - November 11, 1996, Page 5

N
Insect Control Checklist for Animal Operations
Source Cause BWs to Control Insects Site Specific Practices
uid
Flush Gutters Accumulation of solids M' Flush system Is designed sad operated
sufficiently to remove accumulated solids from
gutters as designed.
VRemove bridging of accumulated solids at
discharge
Lagoons and Pits Crusted Solids Maintain lagoons, settling basins and pits where
pest breedlhg Is apparent to minimize the
crusting of solids to a depth of no more than 6 -
8 Inches over more than 30% ofsurface.
Excessive Vegetative Decaying vegetation Maintaln vegetative control along banks of
Growth lagoons and other Impoundments to prevent
accumulation of decaying vegetative matter
along watees edge on Impoundment's perimeter.
Feeders Feed Spillage Gr Design, operate and maintain feed systems (e.g.,
bunkers and -troughs) to minimize the
accumulation of decaying wastage.
fK Clean up spillage on a routine basis (e.g., 7. 10
day Interval during summer; 15.30 day Interval
during winter).
Feed Storage Accumulations of feed residues Reduce moisture accumulation within and
around Immediate perimeter of feed storage
areas by Insuring drainage away from site
and/or provldMg adequate containment (e'.g.,
covered bin for brewer's grain and similar high
moisture grain products).
❑ Inspect for and remove or break up accumulated
solids in rilter strips around reed storage as
needed,
AMIC - November 11, 1996, Page I

Source Cause
Animal Holding Areas Accumulations of animal wastes ❑
and feed wastage
❑
Dry Manure Handling Accumulations of animal wastes ❑
Systems
,O
BMPs to Control Insects. Site Specific Practices
Eliminate low areas that trap moisture along
fences and other locations where waste
accumulates and disturbance by animals Is
minimal.
Maintain fence rows and filter strips around
animal holding areas to minimize
accumulations of wastes (i.e., inspect for and
remove or break up accumulated solids as
needed)..
Remove spillage on a routine basis (e.g., 7. 10
day Interval during summer; IS-30 day interval
during winter) where manure Is loaded for land
application or disposal.
Provide for adequate drainage around manure
stockpiles.
Inspect for and remove or break up accumulated
wastes In filter strips around stockpiles and
manure handling areas as needed.
For more information contact the Cooperative Extension Service, Dcpartmerit of Entomology, Box 7613, North Carolina State University,
Raleigh, NC, 27695.7613,
•a
AM IC • November 11, 1996, Page 2

-,��ti� �uw�ub\r4 •�4rit a�A44llVl:[J
(check which method(s) are being implemented)
❑ Burial three feet beneath the surface of the ground within 24 hours after
knowledge of the death. The burial must be at least 300 feet from any flowing
stream or public body of water.
Cr Rendering at.a rendering plant licensed under G.S. 106-168.7
Sds�S A A-r- 5 rre vex Am i K4 At_. CQuecn o�1 sy r
❑ ' Complete incineration
❑ In the case of dead poultry only, placing in a disposal pit of a size and design
approved by the Department of Agriculture
❑ Any method which in the professional opinion of the State Veterinarian would
make possible the salvage of part of a dead animal's value without endangering
human or animal health. (Written approval of the State Veterinarian must be
attached)
December 18. 1996

Swine Farm Waste Management Odor Control Checklist
Source Cause BMPs to Minlmlze Odor Site Specific Practices
Farmstead Swine production Er Vegetative or wooded buffers;
❑ Recommended best management practices;
2"' Good Judgment and common sense
Animal body surfaces Dirty manure -covered animals W Dry floors
Floor surfaces Wet manure -covered floors W Slotted floors;
E Walerers located over slotted floors;
❑ Feeders at high end of solid floors;
❑ Scrape manure buildup from floors;'
O Underfloor ventilation for drying
Manure collection pits Urine; F Frequent inanure removal by flush, pit recharge,
Partial microbial decomposition or scrape;
❑ Underfloor ventilation
Ventilation exhaust fans Volatile gases; Fan maintenance;
Dust Effleient air movement
Indoor surfaces Dust Washdown between groups of animals;
❑ Feed additives;
❑ Feeder covers;
eFeed delivery downspout extenders to feeder
covers
Flush tanks Agitation of recycled lagoon ❑ Flush tank coven;
liquid while tanks are filling 0 Extend fill lines to near bottom of tanks wish
and'siphon vents_
Flush alloys Agitation during wastewater ❑ Underfloor flush with underfloor ventilation
conveyance
Pi l recharge points • Agitation of recycled lagoon Exlend recharge lines to near boltom of pits ry
liquid while pits are filling with anti-slphon vents
Lift stations • Agitation during sump tank ❑ Sump tank covers
filling and drawdown
Outside drain collection Agitation during wastewater ❑ Box covers
or junction boxes conveyance
AMOC -November 11, 1996, Page 3

Source Cause BMPs to Minimize Oddr Site Specific Practices
End of drainpipes at • Agitation during wastewater 9 Extend discharge point of pipes underneath
lagoon conveyance . lagoon Iiquid level
Lagoon surfaces • Volatile gas emissions; 11 Proper lagoon liquid capacity;
• Biological mixing; 2--bortect lagoon startup procedures;
• Agitation ❑ Minimum surface area -to -volume ratio;
U/Minimum agitation when,pumping;
❑ Mechanical aeration;
❑ Proven biological additives
Irrigation sprinkler • High pressure agitation;. ti"irrigate on dry days with little or no wind;
nozzles . Wind drift ❑ Minimum recommended operating pressure;
I"Pump Intake near lagoon liquid surface;
O Pump from second -stage lagoon
Storage tank or basin • Partial microbial decomposition; ❑ Bottom or midlevel loading;
surface . Mixing while filling; ❑ Tank covers;
• Agitation when emptying ❑ Basin surface mats of solids;
-
❑
Proven biological additives or oxidants
Settling basin surface
• Partial microbial decomposition;
❑
Extend drainpipe outlets underneath liquid
• Mixing while filling;
level;
• Agitation when emptying
O
Removdsettled solids regularly
Manure, slurry or sludge
• Agitation when spreading;
❑
Soil Injection of slurry/sludges;
spreader outlets
. Volatile gas emissions
❑
Wash residual manure from spreader after use; 4
❑
Proven biological additives or oxidants
Uncovered manure,
• Volatile gas emissions while
❑
Soil injection of slurry/sludges
slurry or sludge on field
drying
❑
Soil incorporation within 48 hrs.;
surfaces
❑
Spread in thin uniform layers for rapid drying;
O
Proven biological additives or oxidants
Dead animals
• Carcass decomposition
V Proper disposition of carcasses
Dead animal disposal
• Carcass decomposition
❑
Complete covering of carcasses in burial pits;
pits
❑
Proper location/construction of disposal pits
Incinerators
• incomplete combustion
❑
Secondary stock burners
AMOC - November 11, 1996, Page 4

GROWER:
ADDRESS:
COUNTY: BLADEN
Emergency Action Plan
ED
CHECKED BY:
DATE:
SHEET 1
JES
07/17/98
OF 2
Using this outline as guidance, you should develop a specific -emergency action plan for your
waste handling system.. This plan will be implemented in the event that wastes from your
operation are leaking, overflowing, or running off the site. You should NOT wait until wastes
reach surface water or leave your property to consider that you have a problem. You should
make every effort to ensure that this does not happen. This plan should be available to all
employees at the facility, as accidents, leaks, and breaks could happen at any time. Your
plan should follow this format:
1. Stop the release of wastes. Depending on the situation, this may or may not be
possible. Suggested responses to problems are listed below:
A. Lagoon overflow -possible solutions are:
add soil to berm to temporarily increase elevation of dam —any permanent
alteration of the dam should be approved by a qualified professional engineer
or qualified technical specialist
pump wastes to field at an acceptable rate
stop all additional flow to the lagoon (waters) --hold waste in house if possible
call a pumping contractor
make sure no surface water is entering lagoon
NOTE: The above listed activities should be started when your lagoon level has exceeded
the temporary storage level.
B. Runoff from waste application field —actions' include:
immediately stop waste application
create a temporary diversion or berm to contain the waste on the field
incorporate waste to reduce further runoff
C. Leakage from the waste distribution system:
pipes and sprinklers —actions include:
-- stop recycle (flushing system) pump
— stop irrigation pump
— close valves to eliminate further discharge
— separate pipes to create an air gap and stop flow
flush system, houses, solids separators —actions include:
stop recycle (flushing system) pump
stop irrigation pump
make sure no siphon effect has been created
separate pipes to create an air gap and stop flow
D. Leakage from base or sidewall of lagoon. Often these are seepage as opposed to
flowing leaks —possible action*:
dig a small well or ditch to catch all seepage; put in a submersible
pump, and pump back into lagoon
if holes are caused by burrowing animals, trap or remove animals and
fill holes and compact with a clayey soil
other holes may be likewise temporarkplugged with clay soil
Murphy Family Farms Engineering P.O. Box 759, Rose Hill NC 28458 (910) 289-21 i 1

GROWER:
ADDRESS:
COUNTY: BLADEN
)ESIGNED BY: CHB
CHECKED BY: JES
DATE: 07/ 17/98
SHEET 2 OF 2
rLagoon problems require the consultation of an inaiviouai experience❑ in the
design and construction of lagoons for permanent repair measures._
2. Assess the extent of the spill and note any obvious damages.
A. Did the waste reach any surface water?
B. Approximately how much was released and for what duration?
C. Any damage noted, such as employee injury, fish kills, or property damage?
3. Contact appropriate agencies.
A. During normal business hours, call your DWQ regional office, at 919-486-1541
after hours, emergency number: 910-733---3942. Your phone call should
include: your name, name and exact location of facility, telephone number,
the details of incident from item 2 above, and the location or direction
of movement of the spill, weather and wind conditions, what corrective
measures have been undertaken, and the seriousness of the situation.
B. If spill leaves, or is likely to leave, property or enters surface waters, call
local emergency management service (EMS) at 910-862-6760.
C. Instruct EMS to contact local Health Department.
D. Contact local Soil and Water Conservation District Natural Resources Conservation
Service office at 910-862-6936 for advice/technical assistance. The
Extension Service can be reached 910--862-4591 for advice/technical assistance.
E. Contact Murphy Family Farms Land and Nutrient Management Department at 910---
289-2111 for advice/technical assistance.
4. Implement procedures as advised by DWQ and technical assistance agencies to rectify
the damage, repair the system, and reassess the waste management plan to keep
problems with release of wastes from happening again.
BLADEN COUNTY COOPERATIVE EXTENSION SERVICE
PO BOX 248, ELIZABETHTOWN, NC 28337
910— 862— 4591
BLADEN COUNTY SOIL AND WATER CONSERVATION DISTRICT
ROOM 122 AGRICULTURAL SERVICE CENTER
ICE PLANT RD, ELIZABETHTOWN, NC 28337 — 9409
910— 862— 6936
BLADEN COUNTY EMERGENCY MANAGEMENT SYSTEM
PO BOX 1635, ELIZABETHTOWN, NC 28337
910— 862— 6760
DIVISION OF WATER QUALITY
WACHOVIA BUILDING SUITE 714
FAYETTEILLE, NC 28301-5043
919-486-1541
Murphy Family Farms Engineering P.O. Box 759, Rose Hill NC 28456 [phone]

GROWER: DESIGNED BY: CHB
ADDRESS: CHECKED BY: JES
DATE: 07/17/98
COUNTY: BLADEN SHEET 1 OF 2
Emergency Action Plan
Using this outline as guidance, you should develop a specific -emergency action plan for your
waste handling system.. This plan will be implemented in the event that wastes from your
operation are.leaking, overflowing, or running off the site. You should NOT wait until wastes
reach surface water or leave your property to consider that you have a problem. You should
make every effort to ensure that this does not happen. This plan should be available to all
employees at the facility, as accidents, leaks, and breaks could happen at any time. Your
plan should follow this format:
1. Stop the release of wastes. Depending on the situation, this may or may not be
possible. Suggested responses to problems are listed below:
A. Lagoon overflow -possible solutions are:
add soil to berm to temporarily increase elevation of dam --any permanent
alteration of the dam should be approved by a qualified professional engineer
or qualified technical specialist
pump wastes to field at an acceptable rate
stop all additional flow to the lagoon (waters) --hold waste in house if possible
call a pumping contractor
make sure no surface water is entering lagoon
NOTE: The above listed activities should be started when your lagoon level has exceeded
the temporary storage level.
B. Runoff from waste application field —actions inbiude:
immediately stop waste application
create a temporary diversion or berm to contain the waste on the field
incorporate waste to reduce further runoff
C. Leakage from the waste distribution system:
pipes and sprinklers —actions include:
— stop recycle (flushing system) pump
— stop irrigation pump
— close valves to eliminate further discharge
— separate pipes to create an air gap and stop flow
flush system, houses, solids separators —actions include:
— stop recycle (flushing system) pump
— stop irrigation pump
— make sure no siphon effect has been created
— separate pipes to create an air gap and stop flow
D. Leakage from base or sidewall of lagoon. Often these are seepage as opposed to
flowing leaks —possible action:
dig a small well or ditch to catch all seepage; put in a submersible
pump, and pump back into lagoon
if holes are caused by burrowing animals, trap or remove animals and
fill holes and compact with a clayey soil
other holes maybe likewise temporarily paged with clay soil
Murphy Family Farms Engineering P.O. Box 759, Rose Hill NO 28456 [phone]

ADDRESS:
CHECKED BY: JES
DATE: 07/17/98
COUNTY: BLADEN SHEET 2 OF 2
*Lagoon problems require the consultation of an individual experienced in the
design and construction of lagoons for permanent repair measures..
2. Assess the extent of the spill and note any obvious damages.
A. Did the waste reach any surface water?
B. Approximately how much was released and for what duration?
C. Any damage noted, such as employee injury, fish kills, or property damage?
3. Contact appropriate agencies.
A. During normal business hours, call your DWQ regional office, at 919-486-1541
after hours, emergency number: 910-733-3942. Your phone call should
include: your name, name and exact location of facility, telephone number,
the details of incident from item 2 above, and the location or direction
of movement of the spill,.weather and wind conditions, what corrective
measures have been undertaken, and the seriousness of the situation.
B. If spill leaves, or is likely to leave, property or enters surface waters, call
local emergency management service (EMS) at 910-862-6760.
C. Instruct EMS to contact local Health Department.
D. Contact local Soil and Water Conservation District Natural Resources Conservation
Service office at 910-862-6936 for advice/technical assistance. The
Extension Service can be reached 910-862-4591 for advice/technical assistance.
E. Contact Murphy Family Farms Land and Nutrient Management Department at 910-
289-2111 for adviceltechnical assistance.
4. Implement procedures as advised by DWQ and technical assistance agencies to rectify
the damage, repair the system, and reassess the waste management plan to keep
problems with release of wastes from happening again.
BLADEN COUNTY COOPERATIVE EXTENSION SERVICE
PO BOX 248, ELIZABETHTOWN, NC 28337
910— 862— 4591
BLADEN COUNTY SOIL AND WATER CONSERVATION DISTRICT
ROOM 122 AGRICULTURAL SERVICE CENTER
ICE PLANT RD, ELIZABETHTOWN, NC 28337 — 9409
910— 862— 6936
BLADEN COUNTY EMERGENCY MANAGEMENT SYSTEM
PO BOX 1635, ELIZABETHTOWN, NC 28337
910— 862— 6760
DIVISION OF WATER QUALITY
WACHOVIA BUILDING SUITE 714
FAYETTEILLE, NC 28301-5043
919-486-1541
Murphy Family Farms Engineering P.O. Box 759, Rose Hill NC 28458 (910) 289--2111

Singletar
V_ un
.4 -M -M LM % Primarily us
camping, Sing
has one unit
camping,
Pri
marily
in
ar
ingl
has one
mess hail and
andwash
nd wash how
east of Elizabet
&A KE 5 1
CI -PRESS CR= 53, the 1,221
fishing,
s i � t
shing, boatir�
i
M campers.
'41. F
JL
LM
air, COLLY
UL
wnws
A POND
0
LAX,
\3 UA.
A
BLADEN
JON
CAKE
ILI
7.
Ywidt
LAKE BIG
BAY
Lin
..ITE
LLU
ICE
EULABETHTOW
ATE
V, LOCK Sr-
SINGLE7'ARY
LAKE
TUSSOCK
BAY
J3 L7JU 3
P
-re -in
S.

"it tt� �-.{�; ': $'� ! r �Il,'n r Pi. :ff �r �', ['- •��.; :, .•� / r•�n''' 1�i• �'�-ri}'t •. ��� 1
Y�i{?, {:'j'�, 1'�'7 t'.iY i'•!LW..��Y C� L :If' ,%J',j ;P 5 r. 1 ''r ..f' r �n ,�I�•t �.a �.}•. .'1:.ti: l.'�.'.
k �,_ ��• - �'•�/t•_�,�[il.T:_,,���,g.. L. .,,+�,,� 4,� �,J,i i. T: a •1.:'�!� Ifl �ry{','��.,�.• 1 �• . •5i'.•`.1'4'`, 1'}q, �++
►F�4''wF,`.: ".. Il~'"•:ti� IL•�!::•r cw rn;1fi��1q�;�i�;t.. r~M 'ate•` >�r'. •;J, !rr, 1. ,y4
.��~~w,w �.~r '�!• r .;"t.«.. � r :,t,.. r�. +f ` -. r JS I:r'? f -r '� � I
i'j.y 'Mq ry •ay 1• r ,I i, y j �rf/`Fy'%�j• 1 � y, 'I � r r'
"i- .• ••1~' •j '}i ' � •�,! •4 LAW�,�' N la �• �4: � ' �� Il '�� T ..
7lr' i{ • t .�'... L ' " ' r"
. •?'fr' - !_ •a`'''I, .• —.,a •yam. .'11..1. ■lZ'i i, r. (1 r•• .t ,!1 . .; t J J 1 '`r•' Y;: �.".
w„�►�7Jf u.a .�1�17„•a+,� ~ '�5 �..s•, .r� ii -:y �,•a-"r
,�, `1 .: r•: �'��w 41 ,r.`'�a�'4.•,1 �y+(•�'}•:.i."e,� f u`'s�.� "tip 1'�' ,''' � � .•'. - ;'�. ,
n_ . �; .. i1• °�' a,. �. •a�•- i •'�l,r,!', :';r.�:: ` ,r • ,:e.,.,ti;�- . .,�} /fCI+Sp..,•i � ; �,, ,>, ' r • 1.
- �, . •11 v t [,, .4.�-� ;`!' .~1.�'l, l'4y .'Y. t I..�'k,',f���•�.' :.jjri r�„'!; •" ,�:-` � 1' :a''�•�
�•t ,,l• ''rr"'.'1}il.':.; r('T �:,Ir' 'r�t/�, :.• .s`` ,�„M,. .1• 'y4 �'' r '_!; .'1 ti•,
r .� Y :I�. l' '[ C 1''1 .t•'� .1. 1�„�, '1�, ;'C.L'.:�L .. �i {L�fri•`' 'iit �c �'�[ +'i t,
'l%. �,). •j1,;.4 +�l,J,.'�u1' 1 r ,. ,� •'. _ .Za;T?I::).i, `nl.<,I ;'.. et1 •l�,�i' '�i',1
L� ! •. 5'� .'• -1'. ' �• 1„1„' : r f.,�'f .� I • �14 1 * .�i.' it',: :5`.
'•�' +ir rL� •'.� . aka." �7' '., .r.,.,..
,rl )J 4' ',(i• •S''\f'(� .,1 .I"� 'J'• �-Iq i1l,i'" ! ."4 �.[ .,�;',
r' 7 I 'i.:�.). .',f' ,•1 ,1':1 ��'t'' .l`y"'\'�.J -5�r�
:f�•: :VI•''�t'�. .7.. [ 'L�...r.
,I'. :1 fA[y ,5•r' ..}. i'�' .,:`Z1,1• /�!`�i .i •.4'': ��.\„L•„ J..S` ,L,, :i.
%•' 1 n, •,i it .•' `":�•'' I �L*,. �'J' , ' •
I'; •T . �t ;'f'• ':1 :.1 1. S. ,il" 'V
L' ( r'1" •, j�y LyJy 'Y ` 'j ,1' ]] .L 1 L. 'i'�. '.i��' 1. .5'.
i.r C:,' t1.1,': {' (`(, 1f �1�' .irk^... / II` t(° ,, r'Th 'i,.• l;' ':Ii,�'L•':'•''i•'s;'
.� !.r, 'r' : i", .�• r( LV!'. ;.f '( '1• J i '.r . !''4 S k• � i, i�'r'� !4' 1 .�:I r �� r.:. •.' ' - [ 17':
,. r.f' � � "I:T '�',11":I�%''7� Ai'� �1 r.11 �i'i.'S .''j• r'♦ Yf� ) �I, ,i��^Ki'AA�KI:'. •:``'. �•`i �'�• it ;1'' . ,i.�.�\
•f Ic �„1„.Es L.,1,��,F'. ;JI'• ,i�il';:'i;'..�� f,,, 1'` }�I:• ti 1 ti"1 ri' 1 1�; -'•;�, ^i,,(t. ;�, .1
I(/i1 ; r r �l, rl',y,.'ti: l 4 S r, rY (, k'I �1 t (i e'.� ''� ` i �:1;-'• }��
1 r'r i� r'��r 14+.,r• .Si �1��';i ,� ff�rf�7 {r.'1}. �:( 1,, .(�..." ,�'��; ,�.,;, '•,,. Yr
1 rl �y'i J, Y M 't' I! I i � % '': , tr. I�' • T if . � •.S,
C^�i �'F �" ,1/I i; 4`r4i r'1 :r:�t:l' ;�� .y `: •,.
• t "�,�'1�'��Y.';'�''''1 d:�,�]� 1`t 1'i �1►'fi'� (� �1�:,,,... .. ';s''it •,;y' •� ,.
yr. � It;3 L ti�s } +1. +1� I
1 r'i.••, :• ', I' Y � r,'Lv 3it��Il N,I 1j '�► •�, r ''•, '.41'' �'�i1:"�, ,1 �. r' i i` .a
,,"�IWF'-'RlNf� 'kl, ,+,I.�il+ri' Ir,14 ,'f :y,���S1,S (:;h�''I� r '/4 �y' �' �. rl r . ?I., •• t'�,�a,1 r• ,.' '}r'`� �+ J ',laf t '' r4 IVY
'': 'K. '�•'�I1 / 'I'•''.1. I y�c/I�� ,1'..1 Jry ,'L , fr1 °1} ,i "i.''. !°,. '/. •e;::' .,!"•�';:;,
`ro' 1 :,; ;'•'>4?•tF1'}•a�{)jj� ' r '1 3 T '��� x~,. r, C'''I[ ir,r 4"'•� �'�• '� � .{ I a' �','. 1,
•.:: -�'+.. `I,(•1 1.I';1,{� { _ .+r,� r:,�_. ,+�•. ` •'', 1.. .1�: \'�i �`: "/1j�y,/y '1�' L.
:h a.f'. i5,. •,l. ,,►i� 1`�JJ � e,: i. ''r':' �•' ! ;.��L- � ^}i. .. '�. .�a .l' :'1; .': .i,• ,i
l•:�r..n•r •'°' 'r�, a �''.��• t•� 1� L'r T�/" •/.ti: `''',i.', � •r :�. � �'•i
I' 1 7 4 'r l.� '�t � "4� •f.
•1 lli �'L
I�, a !IV' •r'1''
F �•
IA
It
F
i l JJ
tF JI1 ,
It
,r
.l
I'
,r' •r. �� r
•� 1• ,Ij ''IY
rl l..
Mj
NO
J.7 •
l
d.

>a '
u
FE
rl r1r i'rrJl' rl.lJr �•j•'`., !If I.
�• r �ir
I
1.7 Or f'1
•<1
t�
')tiff{.'t • �.,A' '';,,., :•7 '. •t'•,Si•' t.,.'';r',: ,,li,p,4i,r:
f 1
,�'• �J`f I t�
s 4 ; li r S 'Al
!r r I ; j �l., � , 4�✓r'�,7 kr. � �+-t a,l.',',#`�j �I-+ ' rlf; -", 1
.r?ii � u }1 r, i siSf '��.�• � ar7' �,• ri r '1 I1 � ,+
,t'jr;+s..�; ""I ` Ji 1'�''J.;r, ,. ',4j(, �•,,�,�' 'lli c i; 1 t , i s }ifs. r ! ^ I �
r,�.',ti,l, .�.1':•M'.,I.{i`'�, �i?Y •� 1' 1R! � 1r'q fJfreNll�li'.,A ii'.i ��. ''i:•' r } i �tY. �i .,: C.• :7 �J1r, t.';li'.
{;'I 7��1.j' +1 "�1. {1 'vJ. 'i3l'r`f� 'I� Y .•tii s'f' i �' k� J- t1, y ! ,.. J";1�i 1'�:.'f'.,': :� 1 �. 'l
''f1�11�, r4r }rIY {'�i�p', �� '- 7�� rl r `.i , },y!!'; �ij '� '�, t I h .,, '�..�'�t.'7 ' r1t' '•'I �'
`% i I 6651�. `;i .}j'' i ,1 rf � �:>✓'I'} r,{r .l,� r,' 1 '+ s' I:}', + 'I ,
``�ry�-i'"�'fP� � X �' !1i• 1 f , ,y f= �' --.: �. {7'..�,, r. l't
,, 'II� it rpJ�l ti� 1,;i f� it. d' �J, ?, 'rJi:4T�� �'''� �m , 1� r7'r f ��S'; '''11: � t. :•re
(c '�' '• ' � ,f i � '��'�' frf7'�„f..g yR''i�''R ' + �''t ", , ,:'.f. �'; 1;•!'.�i�?r � � r
. ;7 ��„ ''� � •7',' F,f ,�' � L g � rfe-� 1� 1 .,,, r e,'.. ,.I .�
rf- fr fr h,^' )p •'�i) � jr�-15•' �i;lre t. � S�l.y„lr,l•�?.w , i
�uf�{l n' " 1� J , �`1. !)/jA'I�I1 {;•!i� b �1 �."� �;f ti. �=ti ekr l! r I'7; J s�,;�ieili �'l S� '{' -
�-i(��r, ^'' r. Y 'll �• jT'� {Sf �� �-1��1 �S��i iif. ?rj i )', l ;,r lY•.. r JS•}rhe�'�t�;. ' 1. �?
11�:7. �'�14 f i �,� 7, ;^l;t iyj �i t.�, 5i l,,t � .t..�frr M`1 `> 1�vt1i7ii 4. .'y jri + ,''1i'fi ��1 u�;,�'.♦ir '1 1`' �I
�1� �� � ,1a:4lir �' tr,a f i !"r' �+'"f 7��' t r i �4 � 11� Y� it � f`'�'� 1',f ,`! ,h r ;I• }�eh )�. is r + i '• '
��'•,r j1� %r. }:�•3 I , 7 ,� i,• { ,,aryl kr I ,y r /� JJ f I r �,,y, 11 Y.� �' �� ! r '''.
)Ili
�' i �i `1 �' is '� i1. ,1, I � R' �r r4:'�ii' ���' { t�j,•rt��: V� + .1�': i,il. '.+,• ,;, ,

� '�. � „h; "'�PJyrti> y f+"\+ ''+} rp k w,;yy'^' , a'rIG'$�r'•
i • r, �:t' rwr ; i,::'�ryy �� : ; L :.;r ��j�l' j;.�;S:7�'�i 'A{t j�; T,p �t � 1tJ c
t t, I •J ra•7`' lji�'i r'-f, ;t'J# tl,r f Y yy 'tih= �uw!r'r;��';•{'. h '+ i' a! i
st � } �• .��' �f�y
i�,; '.r 'ti' �t,1 'r'' ;f3' 1 .:;crt •; �r r 1 � r,• ;i'r ,+,; ,,,' r' I
l 4 �,"?1�' r,i:;r.T•r:,i0. i, .. fig': ./:'.�If';'fi+,}r_"1..,' +f.;, t��y��,.,lr.�( ��',y r �;� •�.. Ji.45� -
r.,
•�r � 1 -� ri 'sr •' 4 � - r�v h' (ir i1j', 14S�f
3�y q c•1, r I �b2! f t �xS' kr ur'',rr x ,� rr('I1:� F 9N`�j'Ii n�Zv. Sys ti•,rlJ;+ f r, 711ti ,.�.`
FEN
!
•� M .ja�� , � �J ,'.. 3 �i r �( - r� r���><�i r}a7•
�jr f e t MAN q
F 1\� n�V'ff�'I �� r1} ,�'+ i{ r, y 1r '. I.tu,t� fJ ek'trP"�rY%�r •�' 1, } idy ..L l:1 I
r 1 ,•.�f� 11 k �, t} r 'ai .�r�r ' �_ � a f'tr II. l•r. I ! 1 �Yr y ,� n '\i r, r AYT' Y �''+�
RAN
F1�1
yy
r 1
'•, .�krl �fl;�t,i , ". ti r J t��! } r^ rr, rr �`'j.
%}r} �IyI ICI,. L1-
ti1�'1
fh µr'tr,4j,� lt.i�i1+Y"r`1 r i �1 �r1�h Ad.•,�y •!' r I , t rrl- !r r1 r1� �4 *' `'
ot
-'�� � i t I',J ., a1 n.. .� ° r' •.' �. r n`�r 1 !� jr� t 1i�nkf,; 71kj�J' ,
I I•N���4, k'%^ 'r t'r-9 r� r 1 �1 } [. ' �tr 3 r r .,��! , 1:��il.}iy.
9L;
• }q ` 11 ,'J1 ti .. S`y,1 4 fy_ r 7 5 y jr'� t rtr/ rr J s l�r��}�r�r� I�.�"i•F :1 i._ ',' r' L,,f",'T,, •r. �!
ti4rF R1�
l T•f:r 11< +1 " i•1.i,
j .h It1,.1 r f',�;.i
� gka�jj I I, 1, r � ��y� j r. r 1 ' { • Jt ...,.:.f � ),a i �}r r � k �t �tkrJ ' ��j�r'�t�1
'� `���'� �.f (f 1 � r r' s r .,� � ," � I 1 2� � + I }' - *- �r•'( � �` ,`I '•A, li 1'r�'
,V`� PrI I'd,' �� i f J(♦ _ ,�' Irlf Sk, <<} Ili r•r.`p7 a,�
•�'''ii1�"•J:.'3' "b1 - , tt i�' � � rt t 1.i,'-^v tk. ,.. �
+ hr:.kt:jr
..:'l;�;:r r.' 1�4;f ,!rlr tsr•T.. ;'� V I.f .Fr r } 'I t�l r �! r r.: �,. '��'4 c
�
� � • : r' ,rit-�' f i�., r:'. �.,.! ; r ri ai FI 4 j, ` f 1, k r r, .'o �'�' � ti '
.r � � ,1. .;I.; t': ,i�� r 1'f. r.r! '1 ir: ••r,�'' r�, .��^I lr�1-�,r f�; 7Y .�.,t � ,�'r:�r`' r '1l alflr`r1 ,I�tt• i �i *•j }7'� }� r�J. .�,.��i ,;c �� F, ;.'F•.'�?r, 'r � rl;r•' rr' r`I=,���d': t k.�S.:i
Hk E rr, x 3� .+r-�� Jr � ' �' r'�' -°i,•` ti''�:P;�i+.�r ti� tdt.,C.n. .h [f•�lT
x, i =jj 6�,+ �r k IY•. 'r v�7, rk r ,! rr :}:k i•'f �,� 'L;1: r l.r ,,.._1,J t •S 1� i y'r.. t
�! ^ , tt�,* A` � r, � ,r�' r 1 .rr 1 ..:k: .. ,t •I'�P',�, .( rti •t„�, �i
Ir r,d4 X �n, r> 4 r {'„C�l• Y .lid �
r11J` 11 r''• 1
's i"5.. �k�.:;�,i � �. �. � rlsr:i;k'll.!'r!!k�.�:•,4:.Si7.!^'.N�:iA1:w•J .,r ,r.il:��•'�,1j'r 'f.71� \•�t .. ''f•'s•1+'4
s [`-•: ,,y��1�y -' fir: !f'i ,s kl�.' �i
�+,iSl y.`�t+•�.",tr� .wfl� hs �dE.,kVj`1 .
Tom
j�;A ,
s F�r��l '+;,,tfy .rhRis sr4T�;�•+ �' 'I••'i•1 •i r, � �I•�r�'i �.
r'� ^,rti ,$ , . r r `� ,'f('I;r..,,„ • .
Y ��N�f♦lwrrt F - :G l't i f� f:
lY 1 �1 i Ss�
d
k
I

t
Jae.,..
iV

r4L
E
, 7v� iz.
-V 'Pr
14
Uk
"Zi
!1V
m
m

Producer: C f ecs.5 Cer-, k dN�-se-
�
Location: Sa`7 i btid F0.7�%-�Gv;1i� RA
Telephone: & b-)54 7 - `1 4 0 `-1
Type Operation: LZr-Ar - �e e A e r—
Number of Animals: `30po
(Design Capacity)
/A! F
The «paste from your animal facility must be land applied at a specified rate to prevent
pollution of surface and/or groundwater. The plant nutrients in the animal waste should
be used to reduce the amount of commercial fertilizer required for the crops in the fields
where the waste is to be applied. This waste utilization-plau uses nitrogen as the limiting
nutrient. Waste should be analyzed before each application cycle. Annual soil tests are
strongly encouraged so that all plant nutrients can be balanced for realistic yields of the
crop to be grown.
Several factors are important in implementing your waste utilization plan in order to
maximize the fertilizer value of the waste and to ensure that it is applied in an
environmentally safe manner. Always apply waste based on the needs of the crop to be
grown and the nutrient content of the waste. Do not apply more nitrogen than the crop
can utilize. Soil types are important as they have different infiltration rates, leaching
potentials, cation exchange capacities, and available water holding capacities.. Normally
waste shall not be applied to land eroding at greater than 5 tons per acre per year. With
special precautions, waste may be applied to land eroding at up to 10 tons per acre per
year. Do not apply waste on saturated soils, when it is raining, or when the surface is
frozen. Either of these conditions may result in runoff to surface waters which is not
allowed under DEM regulations. Wind conditions should also be considered to avoid drift
and downwind odor problems. To maximize the value of nutrients for crop production
and to reduce the potential for pollution, the waste should be applied to a growing crop or
applied to bare ground not more than 30 days prior to planting. Injecting the waste or
disking will conserve nutrients and reduce odor problems.
The estimated acres needed to apply the animal waste is based on typical nutrient content
for this type of facility. Acreage requirements should be based on the waste analysis
report from your waste management facility. Attached you will find information on
proper sampling techniques, preparation, and transfer of waste samples to the lab for
analysis.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A
NCAC 2110217 adopted by the Environmental Management Commission.

:gym
Amount of Waste Produced Per Year(rallons 113. tons etc)
4-bnS
JCQ0 animals X�( +ate-Flwaste/animal/year waste/year.
Amount of Plant Available Nitrogen (PAN) Produced Per Year
YCC0 animals X Albs. PAN/animal/year 3fgD lbs. PAN/year. (PAN from N. C. Tech.
Guide Std. 633)
Applying the above amount of waste is a big job. You should plan time and have
appropriate equipment to apply the waste in a timely manner.
The following acreage will, be needed for waste application based on the crop to be grown
and surface applicatiou:
Table l: ACRES OWNED BY PRODUCER
Tract Field Sod Crop Lbs. N Acres Lbs. N Month of
# No_ Tvne Per Ac. * Utilized Annlication
Total
* This N is from animal waste only. If nutrients from other sources such as commercial
fertilizer are applied, they must be accounted for. N must be based on realistic yield
!elation. T
NOTE. The applicator is cautioned that P and K maybe over applied while meeting the N
requirements. Beginning in 1996 the Coastal Zone Management Act will require farmers in
some eastern counties of North Carolina to have a nutrient management plan that addresses
all nutrient.L This plan only addresses Nitrogen.
2

PIS
Table 2: ACRES WITH AGREEMENT OR LONG TERM LEASE
(Agreement with adjacent landowner must be attached)
(Required only if operator does not own
adermate land [SW Required Specification 21)
Y
ovk
Traot Field Soil Crop Lbs. N Acres Lbs. N Month of
# Nn Tvne Per Ac_ * Utilized ADDlication
* See footnote for Table I.
Total l3R • s b l -` F' `i 1
Totals from above Tables
Acres Lbs. N
Utilized
Table 1
Table 2
Total
Amount of N
Surplus ox:!�(
5 b(
_ 5(0G
3a,5(
ySSI-I
38,aa
5H50
Produced
ficit
Til p
1(,
NOTE: The Waste Utilization Plan must contain pro i sions for periodic land
application of sludge at agronomic rates. The sludge will be nutrient rich and will
require precautionary measures to prevent over application of nutrients or other
elements.
3

::�
.. nn�...,._ ..... N w
See attached map.showing the. fields to he used for the utilization of waste water.
Application of Waste by Irrigation
Field Soil Type Crop Application Application
No. Rate (h1d1r) Amount (In.)
w "O L34 f:�r-5 C.,%P- . L/
MS TABLE IS NOT NEEDED IF WASTE IS NOT BEING APPLIED BY IRRIGATION. HOWEVER A SPYaAR TABLE WILL
BE NEEDED FOR DRY T MER OR SLURRY.
Your facility is designed for 110 days of temporary storage and the temporary storage
must be removed on the average of once every �_MONTHS. In no instance should
the volume of waste being stored in your structure exceed Elevation it6ce Sq con a4z�P
34 u3r--
Call the local..Natural Resources Conservation Service (formerly Soil Conservation
Service) or Soil and Water Conservation District office after you receive the waste
analysis report for assistance in detenniniing the amount per acre to apply and the proper
application rate prior to- applying the waste.

:01
• REQUIRED SPECIFICATIONS
1. Animal waste shall not reach surface waters of the state by runoff drift, manmade
conveyances, direct application, or direct discharge during operation or land
application. Any discharge of waste which reaches surface water is prohibited. Illegal
discharges are subject to the assessment of civil penalties of $10,000 per day by the
Division of Environmental Management for every day the discharge continues.
2. The Field Office must have documentation in the design folder that the producer either
awns or has long term access to adequate land on which to properly apply the waste.
If the producer does not own adequate land to properly dispose of waste, he shall
provide NRCS xvith a copy of a written agreement (sample enclosed) with a landowner
who is v ithiu a reasonable proximity, allowing him/her the use of the land for waste
application for the life expectancy of the production facility. It is the responsibility of
the o«ner of the facility to secure an update of the Waste Utilization Plan when there
is a change in the operation, increase in the number of animals, method of utilization,
or available land.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for realistic
crop yields based on soil type, available moisture, historical data, climate conditions,.
and level of management, unless there are regulations that restrict the rate of
application for -other nutrients.
4. Animal waste may be applied to land that has a Resource Management System (RMS)
or an Alternative Conservation System (ACS). If an ACS is used the soil loss shall be
no greater than 10 tons per acre per year and appropriate filter strips will be used
where runoff leaves the field. These filter strips will be in addition to 'Buffers"
required by DEM. [See FOTG Standard 393 - Filter Strips and Standard 390
(Interim) - Riparian Forest Buffers].
5. - Odors can be reduced by injecting the waste or disking after waste application_ Waste
should not be applied when the wind is blowing.
b. When animal waste is to be applied on acres subject to flooding, it will be soil
incorporated on conventionally tilled cropland. When apphed'to conservation tilled
crops or grassland, the waste may be broadcast provided the application does not
occur during a -season prone to flooding. (See "Weather and Climate in North
Carolina" in the Technical Reference - Environment file for guidance.)

REQUIRED SPECIFICATIONS
(continued)
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that
runoff does not occur offsite or to surface waters and in a method which does not
cause drift from the site during application. No"ponding should occur in order to
control conditions conducive to odor or flies and provide uniformity of application_.
S. Animal waste shall not be applied to saturated soils, during rainfall events, or when
the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that no
more than 20 to 25 percent of the leaf area is covered.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils
with a high potential for leaching. Waste nutrient loading rates on these soils should
be held to a rninirrn,m and a suitable winter cover crop planted to take up. released
nutrients. - Waste shall not be applied more than 30 days prior to planting of the crop
on bare soil
11. Animal waste shall not be applied closer than 25 feet to surface water. This distance
may be reduced for waters that are not perennial provided adequate vegetative filter
strips are present. (See Standard 393 - Filter Strips)
12. Anima I waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those
owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and public right-of-
ways.
15. Animal waste shall not be discharged into surface waters, drainageways or wetlands by
a discharge or by over -spraying. Animal waste may be applied to prior converted
wetlands pro,,rided they have been approved as a land application site by a "technical
specialist"_ Animal waste should not be applied on grassed waterways that discbaree
directly into water courses, and only then at agronomic rates provided the application
causes no runoff or drift from the site.

REQUIRED SPECIFICATIONS
(continued)
16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc.,
shall not be discharged into the animal waste management system
17. Lagoons and other uncovered waste containment structures must maintain a maximum
operating level to provide adequate storage for a 25-year, 24-hour storm event in
addition to the one (1) foot mandatory freeboard.
18. A protective cover of appropriate vegetation NNU be established on all disturbed areas
(lagoon embankments, berms, pipe runs, etc.). If needed, special vegetation shall be
pro��ided for these areas and shall be fenced, as necessary, to protect the vegetation.
Vegetation such as trees, shrubs, and other woody species, etc. are limited to areas
where considered appropriate. Lagoon areas should be kept mowed and accessible.
Lagoon berms,and structures should be inspected regularly for evidence of erosion,
leakage, or discharge.
19. If animal production at the facility is to be suspended or terminated, the owner is
responsible for obtaining and implementing a "closure plan" which will eliminate the
possibility of an illegal discharge, pollution and erosion.
20. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular
basis to prevent breakdowns, Ieaks, and spills. A regular maintenance checklist should
be kept on site.

: -
:�:
.,.... �YYA'. ?..:......� �.........,....-..T"„Vm'YScv:,"..;'^...;a:4YYY:....::'i::n.....,,.•....,,.....,.,,.........a..�...............::::a:o...,..,..YY7.Y"..�:v:......,,..,..�.,.........................,.v,`.k:..'L...... ....... .
WASTE UTILIZATION PLAN AGREEMENT
Xame o.f Farm: re-5 f v,�rS c r
O►vner,11fanager Agreement
I (we) understand and will follow and implement the specification and the operation and
maintenance procedures established in the approved animal waste utilization plan for the
farm named above. I (we) know that any expansion to the existing design capacity of the
Waste treatment and storage system or construction of new facilities will require a new
certification to be submitted to the Division of Environment Management (DEM) before
the nevv animals are stocked. I (we) also understand that there must be no discharge of
animal waste from this system to surface wasters of the state from a storm event less
severe than the 25-year, 24-hour storm. The approved plan will be filed on -site at the
farm office and at the office of the local Soil and Water Conservation District and will be
available for review by DEM upon request.
Name of f a cility Owner: ,, ,
(Please print)
Signature: Date:
7/'�
Name of M If diff�r.wnei):
Signature: �` �''%/d Date: g "�
Name o ethnical Speci : (Please print) Kj r t�- e r oe..2 �
Af liatlon: le- �_
Address (Agency): 13. 7
/�Jc a-<Ky 5IZE,
Sign a

k'.
u
I
ANIMAL WASTE UTILIZATION AGREEMENT
(Needed only if additional land has to be leased, etc.)
/Y6A k,,sa n „ Tr. , hereby give permission to
apply animal waste fromhis Waste Utilization S ste on ,EC^ acres of my land for
the duration of time shown below.
I understand that this waste contains nitrogen, phosphorous, potassium, and other trace
elements and when properly applied should not harm my land or crops. I also understand
that the use of waste will reduce my need for commercial fertilizer.
Adjacent Landowner: 'Date: y ty �j
Waste Producer:
Technical Representative Date: - `1
SWCD Representative/ ( Date:
Term of Agreement: - 19 9 7 to a -1 a , 20 0
(Minimum of Ten Years on Cost Shared (terns)
(See Required Specification No. 2.)
E

1
iI� { ,ji.tli r!•vf.
^ r iD +, }y�4' i +' ' C�q� l���y•.'�,S.�i ��1,•''� 1��. 15:� F�r. � f +''� '
[A +S�,
" Gr, Y l,T,3', sa<iVi - .� .�, i]+f,,, i� r•{et -�r Ty' I �fI•,N•�. � I� j} {i' I, y��,;•-ti-� -,, ,+`( s��
{,,, �
�t i L H � '� .r��.�. h� J t - :a�!<• ipaA 1}ral, �i, u
\ /e'N �, ',' G'f,`;rrJ� r,f ii `' 1 0 ' �r •.l �tT`tr�
J�U#r�ir k;y'►';'
'.4 •', 111'' •Iw } `f l i l •r 1 f. f r t�.'.`�,.,' � �`' ��•,
✓aL is `1 Ro f7v,{ Y /1, 4• ]�_��{f�.r S r 11, f� •"A.
�r'I
•,�u ���u+� �'��,_ r� = J.!;. 1t' ; . ((., , P .k: _ 1' ,� , I ,1, i ( ` s � t�F { i•[r
ii y. � ffivA7F". r 1.4 ,�},• '
r x r .. I) �,' '' i,�j t. I fir' r : f• ' ';�'' ' ,"f„"
VAj
x' ' ; ! 1 r1i1, '� If�n, Yf- '�' ' ''f' +•'iti .?d r
,11r�
i f�r'1,(!�''f•i +,a.Ll f+ ]r ,t •'.7i,:, I J ���' °r' .rl -{
+ re
� � f %?If i 'x F •+t. 1 I��rr, r, 5 ti I ,, } r s - �J r {•,i, ,°
t,,J'I,i+
�[' ,j F )mot :f l'-�;.•I" '+ I `, � >I?, } s y ,t
t' T ' + , t1 r j� ' e t:.• � � r• `'� � 5 F,� � if I + r ,t , . 3
•' �Y f /ff_M 1 1 ,..S ,rf �,� r i ..1 I {�', ��` r , , rt r + r, I t 7.'','j •. .'
I+�Yr' t��, fr L' ) r��l J�'' 7 %�I.}r / 1 I I 'i' ' ` •i i
14
�ii'. !. V• II "hr} f � Yfi Yl .�`,..�, +� y, .at �S{ ,'? " I i , ;
'K lif! ,�'r,.,.r ,J ! .r• "•` d,S,r.S', rV ,�Y,,,�>: Ir,',- I .I'''j'f' 1{ �'•
''' +� �•1y]I r 1 y,';1�41p,i �,;1 i '' _ f� tfr 1 :•1',•' •:1 .'t', s..f,� ,
, ,r�r 1, fi jl,,1, !I. 1fr1�. tlf 7r ;;�f; lr'la;, j�1r {.M� ��� �� r�l'�fil{5 h,lirlA ills, r.�i 5y 1 f,+{ i q r ��'i]• y1l I ,
f, 'fS Sj;, r k'�I I I -_li�. ,1 + .+r , LY,iir��, j lr�'( rt �I �+,+ r ,� .rlS .:{�, ': ,'•I � ,
} ' j .:' i �!',I� '`I�- I / k•lf�r� ,i ~ +I(11. � i- .`S` .i, /� i' 1 1t�'
' I r : r • 4• it •"� �1 f : F : ;j i l 1 ; � ' '
1' ,�� ?� •� !� �,,V, '. }, rr'I
�'+ I r 5 rj Y 1� r 11 r,('F f,: -,• 1, f, :?;..I•'l . •,i.'..
•, rr ,�, :�' , s, fua',�,;,, a. }• „tl t, •,f '1�'.],'►• cF f+ ' ]'-
f p, L ., {} I, , ,+;. rr ,Y < �'y''.:l �/,.: ;r,` L•;/� l'h;' 'I, •r1�'.o-. ,
, 't' ' I �I�� '_�, �, Y' ►.:i , �,Y 4'�' �t���{}t'b �`'j+-jr{ r 1r}� �'-". f1, �„ 1�9 T ' i� ; 1 1'! '1,,. ;•.i{ •, ,,'I,'r.:
u''V6''1
fI II� k•~'�,«• I�, �{{{II ' fil r, i�Y C'F (S 1 ',9 } �}1 •IY (1 S I IL'1,
.'
( , y .jr 'r�i• i1pJ�1� s } :' i ° {, r 1 1,1! � i i 1 / s) , i C
-;• 5}u �t Y; r, rr 'r i�v'.„L• .yy+ '�;, �('', I' •
+/ Y i ��41 ,i l I{{M f d it
}`J}I'l+:l
!' / �, �i yl J ! ,,: i r , I ) J1 I ;l . r t'• I �'.Y ',ti!,! � ;1' j ' ,!ji,
it IS �, 1 ,1",�'rl�:�!: r''r,l'1 Y.V t,-j {� L ,1'r•1i. ✓,.+:;

A
tt Z i ,yY, •� �4't ry rMf i 1! h1y�s�,br�.-•
=r,►•
,,�L 2Srf3', r 1 ,,, jt� Ni. + �; tj it��z �'i, `�r� ' "{��r' ����1 t 4+' f•.��t .zf..',
s'•�'' r S ]" r'�f� � } riisr, K � v�,'Ti 31 J r 4 ' -taw � J1
k r !• 0. I r ,� r� il�t i' v r•J ;f;'� yi 5r 11.lrr t' Jjyk ':J Y�ye��} 5Sa({{'r rr61 �,r' r y �yggJ,
,J
t"w•
�.r
Iu'pp� yt �Mt L it tr• a- 4 �f� r, I 1 t yy i� +%�,'Ii 1 S ° - �'�Y+.
Sri"• r f ,fir "S ,, 1 i( FK ���a�jlr�y,r#K.r rx , n:,1, r•''. RL , � eul'i •'''L, h
'1}'_ }JY_ '' y��• ny r,i ' � r ��Y 1 t t���� ,fir �� � �,�'� � �St IL ,4�
5r �,FJ
lv, .� J-art. .I ,I,L�l�i11r
fr .- q"C Itry ryrr wtJ hta 's , % VI rt 4
fr,•.r 1 .,IIn A!KJ 41 r , ,'�yiZ� t Ilr�r;4••,.1 y
0
•, - I ! r Jet-,J . I ,+Ir.l „ r� - r r ,,,,
r � J tt� ' t , r f i 11 r} << O Er #! r`' �,it-` ,,, '• r` fiJi � 4r
�;' +f - 14� �°i.N 1 r' }Y I t i�, t+1, • ' rgrr J . �r � yn r eir •f Nt^
•,� I: rr x r'l J 1 yr �j1 �,f rt IS ' s.ry % r'r �r,. Y 'r n,SrS-!�'I.n +0s1•, j' ..r•- °lra, j,, r` h tx'{r,�r� 14-.I.rl:%:;?.., �''
•�'• 1! '! r •4 _ •,,-?`.k•J �t +� ",•` r�r�l. �}r.F�� � �}.r .f .lf :��� _', ;�, (L '� �`}o,J� �u ,�. � { t.�.'` �•{!
set jt r ft �`r`��r •1 '�1 it 'Fe .t r.,l 4T} r�{i�,',,, rVr i `r4f r�,, 4`l, h JSI yJ i•Ir�'r�
•at if
tI J�
il,,S
'jt, 7 i r I , , �, 7 �r r t , �1i. 'Q f,� I, T�ct :.j' - { ♦ �
�i l e :• ' r.•:C! i t s J , r L' r + t r F.r ,fir .•} i ,,• �
:�' j{ r -! ,{ r � i�{ I 9 r4 I 1 �• 't t j7i'I ', L J r _r �1.1:� . �/�• �F' �F�'r4� 'S � r = F rr�. r,h r- ' �, r
" Di'�r' f r J ; ,�. J , r } r ) � sA� .1 r � � t' 1. ,I��..4 ,•� r'1 i 5 rJ r rr i 1 1rr d � , - �w �-
� J, ;r. �• .- Ji�s n ri i + L � fr � r ,r'r � ,r q !i J / , • F S 'S'� �JOS !•'I S•.{•r•.. ,.�
+� '1 ,'i�� I ' ;'tl:.a'C.•i Ir,rtt l7 L-"t.Y't';• •1 �1. r .s'n�r,t� �,�
'I .••.,q. :r:.,,� r' tr �. 1 s �Il ! ;r � "'�:•-I�:,1• � rS 1 i' r �'
r � ��, :Y�• y4 _ - e � i J't r 1 'ts r �-/A� � j �'4r2 T 'J S ji r 3 L, r� Ir
r �� �r.!�rl�r y;,w, d �F •5r-"'YTh I a v r� , r r � `ryJ' +� 4;, :.77' � � ., ; f{,IJ. �, ��- � '!� �' 1 i\�'r r ' t >•t r{� �-z•,,< Y•• t � :17 �r r 7 Li n , , i �J L r ry R t
) s �rl r"•rs rl:' ' t 'r. .L - -i rjk�i' .� r t u�L sr ;'r , y' I' (l.j+�r �1� "�.!'.tr�..f'.'f•l�-
t..t ,yp,.r.,-,, � r m,.n t t� . Jh•1. rtT; � .fir r.S A. � ? �
{ yr�l rf� i;" �l `I: ..4 ' � f �" iiw. •'!+ t ' it `�-,, i f 'r - s J�9tr'ICY' �!' 1 �-
ljt,rfi.(�h f 1�1 r' ,pi"t,J r'� f;,, '.,Il r., I'� r �, {�,5'
�:, l,;i.' /'.'tr.{y !i•:.,`6 �J I.I .=1i}:y?';tws /�. ��/� ;.ti 1 Ohl }, l�}i` ,, rt r�r` iF•iY}rih.
• :,r - } T�{ +lh� "�.� �A {' �if.� yiM rl 4 �'r ',:+f�rl,�, ' 1 ;�y�5 i ,j. ,f •�(! � { )�� -Lv , Lr+ t i �� r4Y-�. �•l
I1,-;+• �'.iy ,'Y,i 11 ,q. rcl`�„� 'Ar r;{1t,' r�' .r�.':. ,t rj, •11 ] 11'"_'^,�J -iy r .G, •,f ,•� t`R'r
� ra,If �� ar r• � t� �—Lr�=+i�!<'fiJ�jwt,:'•irik �+S•,�/�j •'� r `�,L.il �li.�.V Qi r l ��-�} .c 'n,Y•}��ir'i,�lr' �
>� J � J '.N .]F��i4'• � I $r�l`y. ,rr. •.'7�� rr•��i �. r bfrJd ^�:, M�••r. �ri�:.l. + i{f�rF''�'i�yyj'E!1%,:��, .!}•
,+(Y ..7 �!' j �'I:q;r ,.�"y.r;'r• ,'l•kr., „G .4t, !, ti"'�•�','r '+` ''flr" L
��. ,� �+. r � '; 4�t��ypyr•e.:r'�l'i+, ..rr�:. A;'t�'.;,', '.y .1 1' ri y'. ,�'`��fr'f�;i �,'^;t�,�'��i�:n•''•',�'i.ry:',�I,
1�} 5v.•;' ;tFy w..f.A'. :'n •fly �ifr .•�..�, .,R �..,;4 I, •��J ri'; rays:
4 { 'VYtr r r , n } ' jail,,. 'itl�.
�� •�5�'�t still:='�R,1
� " it ,n, '• �r;t' %rf'-t ...
,t1k' . ��r,f`,�;r:•'. i
'It p 119yY}!• `` �11� „13r;��=11t k�''',��' ..l..w;l;..:rt �' y`yr , L•"G'','
j', n,},hi ij�.[.1�4-,T ,i�' ; �„ j'•r{<, :,.,. y',1 ` �,,, , ` .' � �`�' Pr. a �"\� ...r ,1�.`ir�_. r.�t'Y'I.
J, J+'� ,h�+�' '''. Ir}!1•' j 1 .I I r d r1,� , ''�L:f'r-r
1 Y'i iiwr', f 1 �'v � 7 S1� r r � � t� i �j��;1��,, f`•�, ,J�,r`{1,�, ,�y
•�f� • . 1�.:..�.i'1.=3L�.�+i��Ll�r.,.1r �.1.. rit 4±r4{:>ik�f.:. ^l.•'•� '.1L _.Yl :'.:5,7�K91C�i�
Y
t-.

!'�+ L. , •1Y+. a •�La ,, 11'� ��1►'1 ��rt�Fe Tl •.'•'F,' •�... �•y^,'+•�`/1,•�' ,
:,;� . ��`'I, �- �� .,,:�.,.`• fl.:i {', �,�r�:
. ��',� -1'r- �• t � > .� , l i�,. ,R ''J: �• +' '��`I; 1, yya .' � �►,,}�} f° it�•�r + i
r •r•'��,�rt-}e'' '
;� ` y Ir 1 ,p..�� !r I,r',4 ':A '•r, !1 •'.�y't�,� !J,! {':•�\��y� -
+•sAjp,i.4'A�•+•��,r,(� ��y'1�i.4:t�'1, rr• �.'1;'�ti.•.�'+ ��,� +k�t�' �• ,
.� •' jL�F+1,:rr1�ri',r\ 'r �,''� 1}'f;'• L•,'t„V►,{ l�''71�aYr,�{ a' V
• �11' '' '411 I �','► .'til �,� � 1� a � ' 1A a. r
L �'4• 11'� r 4 �+. 1`� ''' J1• ` 1� .l ! 4 �r�'•r���' ',�� f ► � • 1� •, '1
••�•f/' i� r, � .,'yam �` � I� ALT 7v k i �� �fa'r �' 4� •f4� �1,i*'•y` �,��`�. a� ` •+' ■a
kl'"f+A t. !� !•ray '} . • �; ; � ''� s. + '.
• � a
fir,.. "� ` .` '`� ..•.
�� -J ' � �'� + . � �, • ..' 7�• s.�'y',.�r it ' .f• ;••' ,1 '
:I

•P t r !1. �' f r'1'. ' � 1
1, fJ
'riy �i� 1`'t� 'I 1',I?r{i, •4!'t�i:�.:`irSi; '` `J
`\t '�.�•; y � ' � 1. ,•r 2.'r ,L / !f' .r . t try' �.k,•,
'�s; .` }*� ;, r pit "1: }'•�1•:� ,'�.,•1' .. �f r {'' "n �+ ?-'� +�
14
' ram,. '•r E.Ir.�• il:S'` * •. :.i,.. f ,I }� i {rta •S,; , .k :t��}�
1
1,
41
T�' �. r.� .i'(' +,.�� ��1• _ .j+ �� r �' I J � s �r,,`::1E•' •E
r�
r
l '��Ct'r."�' ' 'a • � :I'�.,• •.,,,, in r ii ,•� �:. •r .Y' ', .:��;5,',�- � � �', ��
��• r Y �. ,I'� y � 11� I I rl� 1� F '-J • •� Yy:, _t
,', �i !� �•'. �. 1r IV �-Jlrl �t Jr 7`�� }f r � 1
! ',r � ��.�! ''*�•� i 1Sr ��yr r, a : � ��y'i��7 �f '�`�1, ,E Ij 3
' i J''' t ! ErIY �� � 'i?, F •��•f' f tl I •'�

V T I
OL
All,
?V
9T.
4A
Ad
7 T
if
fe
t if
44'
N
m

•
•
I
Ills
Ch
Apo
IN
poll
Jm Feb Mir Apr May JM M MG &* oat NM DW
(continue
growth rates for forage crops Obs/acre/d'Ma%ylA

Facility Number and Name: Murphy's 9-9,-Cvpress Creek Nursery Farm
Instructions oil last page
_g
�
M
-ss
RieHNM Lt E
nM
ZW
a
W.
&O,o�
ON
�"
Description of Concern'
we w.,
N
401V g -Ram::
EMS -'F,
ONON-A!, POW -A.
, , 7
-,— -Z
E AM W
-2-I"Mr-MR, M P,
V, j'
AW 5e
WA. N
�. W-1sJ
_,M Q
N _0 -Z
5
M - OR-.
__MOM v
_2 NEI
_5w AM?
ARMS, W21-5101- x_ 4V
- R&M,
I i RM !: 01. 11-W 4--W
tv �
wi fk -'A.- ME.
-
wp� w - �. iii - P
M a. -0 *, , Mx­
- gg PQ NNW-=
gg 8M
A
N22-04 22,1
R,41
MR
_U q �
Response
-n �k
Aw g M.
g7t�
01 7-
wzz
bi�
--al I
w 4 M
g__
a Z:F 'g
ORE
am
YX
S-2 M,
01
111� IN
-M'7417' =- ��- - -- 1-
Q
iqg
A5
A
OR% 4 Tm %� _-M
S.-�M
wgqgg
_50
M
Owl R
.40-
ME 1--P E w;
WiN
IM
gig 13
�z ww'; k . . . . . . . . . . . . . .
W i M; W
M
3: M iiT
-
%.�O
H _� Fji-
G
amt-
gg. M-15,
�
eg
M
gQ y:Ber'ISMM�5 ......... ......
-
;�g�g
Me
-
SUM M79
%X MR-11M - -
FIR
IN W
MI-T X Mew
S�
M 4z nN
Z!-7
-M
� ®R
21,
WORE.
'MW 7 Kv
A
X r,^ r
iiw -xg
_g
pg&
g
Z��L 1A
ws,
DIN
w
HEM
_UF
17 A
---
V I MEAN
M MW M EW5_
Z
"IM MIN ME
SO
55?5M. 510,
: SO
v
NL�_!�-
go
r,
n
51
K T�_-,­
q_ MA
W ti
WRO,
-
g
--at RR
-7 -
'29 W­�_ W. z
.
"FN
I-M
­7.
n
R, 7 MR,

Facility Number and Name: Murphy's 9-9, Cypress Creek Nursery Farm
Insti-tictions on last pa
5
_1-
7
-
Subsurface DrainS3
nA
E
W
1io
P1cat
-r
4N
1�sAr_2-
tructura
M5
& 'g_--'7
LKOPPIfig-MUtO
WIMA_
Description of Concern
Indicated the possibility of subsurface drains
B ing present on e' the permit application for
E
ig:�' 0,
ge
F­V�zgm -g g -
The farm.
Mfg
P1.
Z' NAW
PEM M
M.7
RN
N
0�
Y�Lr
G'O
g:
OR
EOf
N
Response
,d
Irrigation is done on 3 party land.
_4
- Of 01: A
Z
WE-
M­_
RM720' �__ 4
WON �g
51N WM W*�
tp�
Murphy Farms is not aware of an drain
NP
4-M L
C I-S!
'4—
'Fq
r-
tile in the sprayfields or around lagoons.
ef
Ok
R
-ttqg
Mv
W3,
MORE!
A
9SER
M�
N
Ott
Lq_
­-_-
g�
-;-
N M4 W_ -
NOW E
xa
NMI'
UZI-59
N
INEZ, _4 SWNf
WRMW W
as M —0 0_
-g
N�
AW
01'_ ; �ek
0�0_Mi
ar
N
+__._..h¢�� CSaS "iS5401
_5
0=
mg R AM,
NO
WE
*W
­R
RV t-112
73'
g L
AV N—_
4mr frN
TO S Eo.
' *�za
W
------ IN
. . . . . . . . . . . . . . . . .
'CS

I Concerns are based upon DWQ records consisting of deficiencies noted in state inspection reports, NOVs, penalty assessments and/or reports submitted to DWQ by the farm. Carefully
review your records to identify the specific concern or concerns and then describe the concern under the appropriate heading together with a reference to the specific record and the date of
the record (i.e., inspection report dated or NOV dated ___J. With the exception of "discharges," which cover calendar year 2000, concerns are based on DWQ records for the
calendar years beginning January 1, 1996, and ending December 31, 2000.
` Describe in as much detail as possible how the concern has been addressed, or, if it has not been addressed, the measures the farm intends to undertake to address the concern and a
schedule for completing the measures.
3 If subsurface drains are present, state whether you know that the drain(s) is discharging groundwater uncontaminated by hog waste, and if so, the basis for that conclusion.
3

Facility Number and Name: Murphy's 9-9, Cypress Creek Nursery Farm
Instructions on last page
MO
•
1
PE
zP0
Description of Concern
5t-M- RE-
OWN
BY Up.
K
S A
g;
qf
59-
%'Am, -�IFRJW
�Sm -R
- PT % ag 20
07 KPV
�US
L
A v--
-zg
2- W PIO—SON, S
"'MW A
=2M
.
z , MR
Response
- aw
pRW I ., � WN -
no=
07
a
NPR � 0, r U A 16-
-2�k B
may.0 g
zg
r.--
N E
N MR
T
FAR
y -w
-5p
P FEir�
bMIN- F_
2". 40 S
M
T,
WAMME jlg
.': 'Ta. .t'"',.,-' y�-""�-�
*xy
as.7
ggmww��-g
VMS
0 MWI&rz. R
-
44
A�. X-5
-W
_gg
RM
F7,
I
5W
NO IN
3�
^0 �If ASIA--
&I
RIP
W
,7 -'-1
-emu.-
MR* -EW
-M Miq'2-
Iem MNNM - v��
A n
T
nm
gg,
F W-
NO O
--R 0-� W-
9. AM
AW
OR

Facility Number and Name: Murphy's 9-9, Cypress Creek Nursery Farm
Instructions on last page
EU
W-Mg, M
Subsurface Drain S3
%P R
.�,e lieg n--
F
p_. =427'
P Stravffiril S, U
0-M
rope 4Lssues
Description of Concern
Indicated the possibility of subsurface drains
Bein present on the pennit application for
The farm.
2
T=�� � � - ` � a
.:..� ��. n
m�
4g4
IN
-0-S
OEM-
3 IN, Ef R
Response
rd
Irrigation is done on 3 party land.
v ON
CG
WIN
—Ma i
Murphy Farms is not aware of any drain
tile in the sprayfields or around lagoons.
SOO
iwter =­
xgg -�gr
10
15 W&S�
Nit
Q
MH=
YX
REM
E&E MIN
W
OtH
3.
MEM Ma"NEE-M-1-
M�
I Kl 0- R
ON
41Z t 4 OR
11 ®R 0'

' Concerns are based upon DWQ records consisting of deficiencies noted in state inspection reports, NOVs, penalty assessments and/or reports submitted to DWQ by the farm. Carefully
review your records to identify the specific concern or concerns and then describe the concern under the appropriate heading together with a reference to the specific record and the date of
the record (i.e., inspection report dated or NOV dated ___). With the exception of "discharges," which cover calendar year 2000, concerns are based on DWQ records for the
calendar years beginning January 1, 1996, and ending December 31, 2000.
` Describe in as much detail as possible how the concern has been addressed, or, if it has not been addressed, the measures the farm intends to undertake to address the concern and a
schedule for completing the measures.
3 If subsurface drains are present, state whether you know that the drain(s) is discharging groundwater uncontaminated by hog waste, and if so, the basis for that conclusion.
3