040009_CORRESPONDENCE_20171231

`j BROWN CREEK Soil Water Conservation District
1& W S 0 4-1 C) J
USDA Natural Resources Conservation Service
WASTE UTILIZATION PLAN.7,-, � 2 ;,3
Animal waste must be land applied at a specified rate to prevent pollution of surface water and/or groundwater.
Plant nutrients in animal waste should be used to reduce amounts of commercial fertilizer required for crops (in
the fields where the waste is applied). This waste utilization plan uses nitrogen as the limiting nutrient. Waste
should be analyzed before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize fertilizer value of
animal waste; and, to ensure that it is applied in an environmentally safe manner'.
1). Always apply waste based on crop needs and nutrient content of the waste_ Do not apply more nitrogen.
than the crop can utilize.
2). Soil types are important... they have different infiltration rates, leaching potentials, cation exchange
capacities, and available water holding capacities.
3). Normally waste shall not be applied to land erodingat greater than 5 tons per acre per year. With special
precautions, waste may be applied to land eroding at up to 10 tons per acre per year.
4). Do not apply waste on saturated soils, when it is raining, or when the soil surface is frozen. Any of
these conditions may result in runoff to surface waters which is not allowed under NCDWQ regulations.
5). Wind conditions should also be considered to avoid drift and downwind odor problems,
6). To maximize the value of nutrients for crop production and reduce the potential for pollution, waste should
be applied to a growing crop, to bare ground not more than 30 days prior to planting, or, to a forage within
30 days of breaking dormancy, injecting waste or disking will conserve nutrients and reduce odor
problems.
This plan is based on the waste application method shown. Nutrient levels for different application methods are
not the same; therefore, changing application methods in the future will require a change or revision of this plan_
Estimated acres needed to apply the animal waste are based on typical nutrient content for this type of opera-
tion. Actual acreage requirements Should be based on the waste analysis report from your waste management
facility. In some cases a plant analysis may be beneficial- and, allow additional waste to be applied. The land
area receiving waste should be flexible enough to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for the crop being managed and grown.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC 2H.0217
adopted by the Environmental Management Commission.
RECEIVED ! Di;NR ! DWQ
A0UlFFi2'ARRTFr'TlrlN (�FCTION
MAR 31 2004
Page I ANSON COUNTY NC

.jkQw'�-' C=q I FY soil wacer Conscr 3n District Ut Natural Resources Conservation Service
WASTE UTILIZATION PLAN.
Estimated Annual Waste & Nutrient Production
WASTE
APPLY DESIGN SIZE ANNUAL WASTE PLANT AVAILABLE
ANIMAL PROD. UNIT TYPE WASTE SYSTEM METHOD A CAPACITY PROOUCED NITROGEN {PAN}
3552 0.007 acre-inchiunit 68 Ib.lac.-in.
Waste Generation Figures Taut MRCS Tech. Guide - Practice Code 633
Amount of Waste Produced per Year* 24.9 acre -inch aoprox. 575 157 gallons
Amount of MIN Produced per Year 1691 Ib. Plant Available Nitrogen
'Amount of waste praCuced per year does not include excess wash 'Hater or run-off, rf any!!. '
Acolvina all this waste in a timely manner is a bic icb...re-quiring time,21anning and aporapriate a ui meat.
The fdllowine iandlfleid acreage in Table 1 and Table 2 will be needed for waste application based on crop grown
and wasze application rnethad listed. See Appendix 1 for a list of Soil Types, Realistic Yield Expectations, N
Application rates, and Commercial N use assumptions Used to develop this plan. Sep recordkeeping FORMS
(attached) for required waste utilization records that need to be maintained.
Acres Owned b
Tract Field Croc Soils Acres
La. N Total
/Ac.' N 1 Utilized acre -inch Aaoly Month
30001 1A IHybrid Bermuda Hay
246E
1.0
1 196
196.0
2.9
I Mays 1 ,
30001 18 JHybrid Bermuda Hay
2468
I 1.0
4 196
196.0
I 2.9:
1clay 1
30001 2 INybdd Eermuda Hay
5758
I 5.7
245
1396.5
20.5
1 May Seoc
30GOI -lA
IRy rassoverseeded
-2466
1.0
k 100
100.0
1 1.5
see ,vote-�tto�
30001 -1 B
Ryegrass overseeded
2468
1.0
10()
100.0
# 1.5
See ,+tote-Apci
30001 -2
Ryegrass averseeded
575E
5.7
60
285.0 I k.2
1 Seot,?oril
I
I
1
ThiS N is from animal waste only. ITOTAL I 7.7 acs _ _j 2274 lb. I
` Indicates heat this ;leid is being overseeded (i.e. interp{anted}, cr, that winter annuals fctlow summer annuals.
ffnutr'ents from, cthersources such as cammarcial feitilizerare applied. they are accounted forin Appendix 1
CAUTION: P and 'K may be over applie4 while meeting N requirements. In the future, regulations may require fanners in some parts of
North Carolina to have a nutrient management plan that addresses all nutrients ifN, P & K). This plan only addresses !Nitrogen.
Acres with Aqreement or f
La. N Total
Tract Field Crop Soils Acres fAc.' N 1 Utilized acre -inch Apply Month
No rented land far waste Utilization � I
'See fcornotes for Table 1. TOTAL acs 1 lb.
Page 2 :INS01V COCLVT"y NC

1' BROWN CREEK Soil Water Conservation District USDA Natural Resources Conservation Service
WASTE UTILIZATION PLAN.
Totals from Table 1 & Table 2
Acres
Table 1 1 7.7 acs
Table 2 acs
TOTAL F 7.7 acs
Amount of N Produced
***<Deficit> of PAN
Lb.. N Utilized
2274 lb.
lb.
2274 ib.
1691 lb.
-583 Ib.
—Must be 0 (zero) or <Deficit> in order to utilize all the anima! waste N produced!
Table 1 & 2 Notes: - Acres shown are considered to be useable acres... excluding required buffers, filter strips, odd areas,
and perimeter areas where waste cannot be applied or equipment limitations may preclude full application
rates. Actual field acreage may, and likely will be, more than acres shown in the tables.
- See the attached map(s) showing fields referenced in these tables.
- The producer and waste applicator are responsible for ensuring that spreader (or irrigation) equipment
is calibrated, operated properly, and applies the correct rates to the acres shown in the tables_ Failure
to apply recommended rates and amounts of nitrogen shown in the tables may invalidate this plan.
Important information for Application of Li Uid Animal Waste
Refer to Waste. Storage Facility Designl"As Built" Drawings or OEM Plan for amount of temporary
storage time, start pumping elevation & stop pumping elevation.
Irrigation/application rates should not exceed the intake rate for the soil at the time of irrigation... or runoff and pending can occur.
The irrigation/application rate is controlled by initial soil moisture content, soil structure, soil texture, irrigation water droplet size,
and organic solids. The application amount should not exceed the available water holding capacity of the soil at the time of
irrigation nor should the plant available nitrogen (PAN) applied exceed the nitrogen needs of the crop.
The producer and irrigation designer is responsible for ensuring that an irrigation system is installed to properly irrigate animal
waste on the acres shown in Tables 1 & 2. Failure to apply recommended rates and amounts of nitrogen shown in the tables
may invalidate this plan. Application of liquid waste by other methods (honey -wagon, etc.) is the responsibility of the producer.
The following information is provided (bv soil type and crool to plan and evaluate liquid waste aoolication
schedules. These figures represent optimum irrigation or application rateslfreauencies to meet crop water
needs and prevent water runoff.
` Min. Irreg..
Frequency
Soil Type Crop Days Apply Rate ** Apply Amount
5758 Permanent Grass 4 0.5 in/hour 0.5 inches
246B Permanent Grass 4 0.4 in/hour 0.5 inches
From NRCS Tech. Guide, Section 11- ENG - Irrigation Interpretations
' This is the minimum rest period in days between irrigation on the same land area under optimum conditions
' This is the maximum application amount allowed for the soil assuming nitrogen amounts for the
crop are not over applied. In many cases, the application amount shown cannot be applied due to
the nitrogen limitation. This maximum apply amount can be applied under optimum soil conditions.
Page 3 ANSON COUNTY NC

BROWN CREEK Soil Water Conservation District USDA Natural Resources Conservation Service
WASTE UTILIZATION PLAN.
Sludge:
This waste utilization plan must contain provisions for periodic land application of sludge at agronomic
rates. Sludge will be nutrient rich and require precautionary measures to prevent over application
Broadcast Soil incorporated
Estimated Annual PAP{ from Sludge: 270 lbs. N 320 lbs. N
5yr Sludge Accumulation: 1350 lbs. N 1598 lbs. N
Based on a 5 year sludge removal schedule. estimated land area required for sludge disposal is:
7.5 acres of grass based on an application rate of 180 lbs. N oer acre
20.0 acres of com/soybeans based on an application rate of 80 lbs. N per acre All the above figures are only estimates. Actual PAN and land area needed could vary 25A or more depending
on sludge nutrient analysis. soil types, crop. realistic yield. and application method. Likewise, sludge
disposal on a schedule other than every 5 years would drastically alter these estimates
Contact your technical specialist at the BROWN CREEK Soil & Water Conservation District- Natural
Resources Conservation Service (formerly the soil conservation Service) Office in Wadesboro, (704)
694-2710, when you receive a waste analysis report. Request assistance calculating
allowable application rates and amounts prior to applying waste.
Operation constructed to NRCS design and specs, and certified (0.200) 1195. Acreage estimated and irrigation
parameters provided for underground main/hydrant irrigation system design. Field acres in this plan are based
on effective irrigated area from irrigation design as plan was amended 3/24/98. Some woodland being irrigated
outside effective area (60% radius) for some gun sets. Additionally, some small amount of nutrients applied
and not accounted for outside effective 'irrigated area. Waste application equipment in place on farm.
NOTE: Plan revised 1/16/01 to calculate Plant Available Nitro en (PAN) per NRCS Practice Standard 633 for
permitting process.
Page 4 ANSON COUNTY NC

wY ..Y� -'�F�i �� _ } IN1�� S�J1. ��� � ��l w-~ •+" '_ �_ _ 'I .-I .. ••, _ _ `.. ,•i 1'i � � F.. .. `, ;
���. w. I1��1 �' l '�' (� A ' • .[!'�'.,■? • i,'+� .1 r� .�(` \l` •',�, .,•� VL�� �' Z.�,[.; ,1 y 1 ` �i V••� • "•.Y••;-,.
-r "4 � t! �T,f S `,,,'.a4 "7i' ` •C %i { ry .�\►--(.�,�., i •S,r. • t \:- .: -
lA•=�C�- F�.yl„-�' '� ;,, �. c 111...A�!V -:�.ir �,� ti 'ti.::'! � • .�.'1 r� r1 ;'y� :i''•_. 1a.:�i: -` r
:y + 1{ � .1' . ; Yl l'•,,,�i�•K .;'Jr � .Y =.i y .,M• �j',-, } ice"'/ � �� "�'',rl �L
"�LrN N ,'��� ,' lY �• ♦, �n+.: j��;�. �� ��. `- +�" �•' V� 'i .�,f' ^ 1'`� �• � y+�'}�JT . e .a
31
:�Ly,r ! �.• -✓`: % • d j�.r' r9,f11u.- aRf10\ •'�' �_. rest,. ,7 r k�_s.•�"}
•�'.� �I,�. �' ' �? � '' ,.. � `�,;' }fir `y.!/lt :• .
1;J: � � -•'. ~� J .. .. •�';iP.• i.. J� ,4t' r;,,•\�•`• �3. ..� .•��i- i` - 'a�a•a',1r-
.j' ti 7d p..'. '�R _9, ... r' wr..t•;.1;.• _ 1' ;• -'7 -xA ',+�.,
■, + 1
or
.._ ',K,� "' -cam a_-� .' � '-C. 7 ,s _' '�•�} O� ���,s -�s � Y�: � .. ;,)�'r.
r
n y Zl r 1�y%
i� X� � ��'•_ � r._ .��';, '� r `ry ,,,:S ", �1"a � tJ � .,_ �' 1 • �� �'! �
'a'i .1a r : � r -,� '� 1,■{.r'�"i�'YI. riiV'7^�'� '�I.Y � ..7: J'��.
} I � i fir: y � �!+�;'+� � n ` L1 A,. r^ y, - .. � r,f a•':,
' .1 � � � � -' .`r v �.yp�: ..r! � is j ltu} ri� �� � �1 -i. � Act ;�• .�'�•�,.. �'`f�,•r� � � `+r
Z flat
It
r
' , � .• i^ f. y •.y 's �-`.iy' ., f ! � /r:. •, ; .1��.� � '�'fll.� ':� 'S',.1�� At�,V-� �.
I r'. � � .s~ �'" y -r J )'y =. l!� ' r (?�� • IDS .' , UM R JTl='�j].,. , 4� Y"•+ff �'•e7.ax' � +�
.`''�_-- - •� � .,i:�J.�,_,- 11 �. 1. t'1 � .e'w 1 -r:f l�� �,i_ i + + 'J q � `�l
_•% J.
z di s'3�i�,
-•+aa I - Jr - 1 o ,ti i'� u �: ii •�' 'i :f�`!' s ��5it7� ,] ar'r
` "''•- I O f Mom'"' .. a • �?f�� •aj��,�'. �* !••..' ` �,`�, o o ;U � ` JC`_:++'��}:r:/r, ��;:% r,, .
r '� ' r►;rr T;pYj lr '7��: t.t_ry �` '' o
�2�j.•. ,}• ,j.� A)�1.,.,-Ar,
i":lit 1 L}a�.vZ•'+r` 1�� "'AY
. � � ,r � �, �►�tiY4� 1. � �'(,s .�r�� .} .r,�\1_-...+}x v.,f'• •r�wo F
_ ' f .�{-�•-.1� :`� � 'f+i ,"rii' i . ! ' �3�� w\l t4 ' �F,-G��f Tr(,''.• ti > r. i •� /c.
�r A; ' ` I r '� r �''•-fpf•'11if �fu '4�lal /`y. yfv .•1 ^�!S
1� 1rr" „ y�f � f ti '` ,rr • ,ti r y( +- "� MvW1, •.�[I,..t,v
10 AN
l-A

BROWN CREEK Soil Water Conservation District USDA [natural Resources Conservation Service
WASTE UTILIZATION PLAN
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade conveyances, direct applica-
tion or direct discharge during operation or land application. Any discharge of waste which reaches surface water
is prohibited.
2. There must be documentation in the design folder that the producer either owns or has an agreement for use
_ _ of adequate land to properly apply the waste. If the producer does not own adequate land to properly dispose
of waste, helshe shall provide a copy of a written agreement with a landowner who is within reasonable proximity,
allowing use of their land for waste application. The owner of the animal facility is responsible for securing an
updated Waste Utilization Plan when there is a change in the operation.. _such as increased animal numbers,
method of waste application, or change in available land for waste utilization.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for realistic crop ,yields based on soil
type, available moisture, historical data, climate conditions, and level of management, unless there are regulations
that restrict the rate of application of other nutrients.
4. Animal waste may be applied to land eroding less than S tons per acre per year. Waste may be applied to land
eroding at 5 or more tons, but less than 10 tons per acre per year providing grass filter strips are installed where
runoff leaves the field. [See FOTG Standard 393 - Filter Strips],
5. Odors can be reduced by injecting waste or disking after waste application. Waste should not be applied
when the wind is blowing.
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated on conventionally
tilled cropland. When applied to conservation tilled crops or grassland, [he waste may be broadcast provided the
application does not occur during a season prone to flooding. (See "Weather & Climate in North Carolina" in
NRCS Field Office Technical Reference File - ENVIRONMENT for guidance).
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff does not occur offske
or to surface waters and in a method which does not cause drift from the site during application. No ponding
should occur...to control odor and flies.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that the crop is not covered with waste
to a depth that would inhibit growth. The potential for salt damage from animal waste should also be considered.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be held to a minimum and a suitable winter cover
crop planted to take up released nutrients. Waste shall not be applied to crops more than 30 days prior to
planting, or to forages more than 30 days prior to breaking dormancy.
11, Any new swine facility sited on or after October I, 1995 shall comply with the following: Waste application
cannot occur within 50 feet from a residential property boundary; a perennial stream, river, canal or irrigation ditch.
For other animal operations or swine facilities sited before October.1, 1995 - waste application cannot occur within
25 feet of perennial waters [See FOTG Standard 393 - Filter Stripsl. NOTE: Local ordinances may preempt this.
12. Animal waste shall not be applied closer than 100 feet to wells_
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those owned by the landowner.
Page 5 ANSON COUNTY NC

BRAWN CREEK Soil Water Conservarion District USDA Natural Resources Conservation Service
WASTE UTILIZATION PLAN
14. Waste shall be applied in a manner not to reach other property and public right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainaeeways or wetlands by a discharge or by over -
spraying. Animal waste may be applied to prior converted wetlands provided they have been approved as a land
land application site by a "technical specialist". Animal waste should not be applied on gassed waterways that
discharge directly into water courses, and only then at agronomic rates provided the application causes no run-
off or drift from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall not be discharged into
the animal waste management system.
17. A protective cover of appropriate vegetation will be established on all disturbed areas (lagoon embankments,
berms, pipe runs, etc.). Areas shall be fenced, as necessary to protect the vegetation. Vegetation such as
trees, shrubs, and other woody species, etc. are limited to areas where considered appropriate. Lagoon areas
should be kept mowed and accessible. Berms and structures should be inspected regularly for.evidence of
erosion, leakage, or discharge.
18. if animal production at the facility is to be suspended or terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular basis to prevent break-
downs, leaks, and spills. A regular maintenance checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops for direct human consumption.
However, if animal waste is used on crops for human consumption it should only be applied preplan with no further
applications of animal waste during the crop season-
2 1. Highly visible markers shall be installed to mark the top and bottom elevations of the temporary storage (pumping
volume) of all animal waste lagoons. Pumping shall be managed to maintain liquid levels between the markers. A
marker will be required to mark the maximum storage volume for waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least annually at crop sites where
waste is applied. Nitrogen shall be the plant food element that determines application rates. Soil zinc and copper
levels shall be monitored and alternative crop sites used when these elements approach excessive levels, pH shall
be adjusted and maintained for optimum crop production. Soil and waste analysis records shall be maintained for
5 vears. Poultry dry waste application records shall be kept for three (3) years. Waste application records for all
other waste shall be kept for five (5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina regulations.
Page 6 ANSON COUNTY NC

BROWN CREEK Soil Water Conservation District USDA Natural Resources Conservation Service
WASTE UTILIZATION PLAN
Name of Operation: A5�k 61ed -'q., �
Owner/Manager Agreement
I (we)'uriderstand and will follow and implement the specifications and the operation and main-
tenance procedures established in the approved animal waste utilization plan for the farm named
above. I (we) know that any expansion to the existing design capacity of the wasteareatment
and storage system, or'construction of new facilities wilt'require a new certification to: be sub-
mitted to the NorthCarolina Division of Water Quality(NCDWQ) before new animals are stocked.,
(we) also. understand that there must. be no discharge �of animal waste from this system to surface
waters ' of.North Carolina from a storm event less than the 25-year, -hour storm. The approved
plan will be filed on -site at the farm office and at the Brown Cree oil & Water Conservation
District office in Wadesboro, NC. The plan will b vailab f view by NCDWQ upon request.
Facility Owner
���^•��
_ Date:
v Huntley -Vernon Farms Inc
Facility Manager
(if different from owner)
Date:
Person Preparing Phan
t_ � Date:
R. Lin Taylor
Affiliation: USDA -Natural Resources Conservation Service
1706 Morven Road
Wadesboro, NC 28170-3142
Page 7 ANSON COUNTY NC

BROWN CREEK Suit and Water Cunwervatimi District. Appendix 1 USDA Natural Resources Conservation Service
KGaIIS11C
Yield "" Recommended
" Soil Map Estimate Yield Nitrogen application per
Unit symbols CROP (RYE) Unit yield unit
Nitrogen
application Commercial 1
rate planned Nitrogen Used
Nitrogen
Supplied by
Animal
Waste
575E Hybrid Bermudagrass (hay) 5 tons 187 250
245 0
245
246E Hybrid Bermudagrass (hay) 4 tons 150 200
196 0
196
575E Ryegrass overseeded 50 50
50 0
50
246E Ryegrass overseeded 75 100
100 0
100
Ryegrass to drilled into short (<3") bermuda sod by October 15
Waste application Requirements for 100# PAN Application
- last application to bermuda by August 31
- 50# N may be applied to ryegrass Feb - Mar
ryegrass should be harvested by Apr 7... any N applied to ryegrass
Apr -May must be subtracted from PAN for bermuda
NOTES: Yields are based ou Realistic Vivid rxheclations for Soils or North Carolina
rroin N C Stale University.
* Soil -Crop Yield Data from NRCS Field Office Technical Guide - Section 11(unless shown otherwise)
** Recommended N rates from NRCS Field Office Technical Guide - Section IV, 590 Nutrient Management
WASTE UTILIZATION PLAN A1VS0N COUNTY NC

BROW ",FEK Soil Water Cosibiervatimi District
USDA Natural Resources Conservatic ,vice
Checklists for Animal Operations
-er -or Farif y F
Insect Control Checklist - Liquid Waste Systems
Source
BMPs to Control Insects
-
Flush Gutters
Accumulation of Soilids
Flush system is sufficiently designed, and
operated as designed.
Remove bridging of accumulated solids at
discharge.
Lagoons and Pits
Crusted Solids
Maintain lagoon, holding pond, settling basin,
pits to minimize crusting (no more than 6-8
inches over 30% of surface).
Excessive Vegetative Growth
Decaying vegetation
Control Vegetation along perimeter banks of
lagoons and other Structures to prevent
accumulation of vegetative matter,
Feeders
Feed Spillage
Design, operate and maintain feed systems
(e.g. bunkers and troughs) to minimize
accumulation of decaying wastage.
Clean up spillage routinely (e.g., 7-10 day
interval during the summer; 15-30 day interval
during winter).
'Feed Storage
Accumulation of feed
Reduce moisture accumulation within and
residues
around perimeter of feed storage areas by
insuring drainage away from site and/or
providing adequate containment (e.g., covered
bin for brewer's grain and similar high moisture
grain products).
Inspect for and remove or break up
accumulated solids in filter strips around feed
storage as needed.
AMONC01INTY, AC

i31tOW1`' ".Ef:K Suil WJ�Cr Cun�crvrliun DiytriG.
USDA Natural Resources Conservatlo vice
111110,11
Odor Control Checklist - Swine
Source
BMPs to Control Insects
Farmstead
Swine Production
Vegetative or wooded buffers, Recommended
best management practices, Good judgement
and common sense
Animal Body Surfaces
Dirty manure -covered
Dry floors
animals
Floor Surfaces
Wet manure-coverd floors
Slotted floors
Waterers located over slotted floors
Feeders at high end of solid floors
Scrape manure buildup from floors
Under roof ventilation for drying__
Manure Collection pits
Urine, partial microbial
Frequent manure removal by flush, pit
decomposition
recharge, or scrape
Ventilation exhaust fans
Volitile gases, Dust
Fan maintenance, efficient air movement
Indoor Surfaces
Dust
Washdown between groups of animals
Feed additives, Feeder Covers, Feed delivery
downspout extenders
Flush tanks
Flush tank covers; Extend fill lines to near
Agitation of recycled lagoon
bottom of tanks with anti -siphon vents
liquid while tanks are filling
Flush alleys
Agitation during wastewater
Underfloor flush with underfloor ventiliation
conveyence
Pit recharge points
Extend recharge lines to near bottom of pits
Agitation of recycled lagoon
with anti -siphon vents
liquid while pits are filling
Lift Stations
Agitation during sump tank
Sump tank covers
filling and drawdown
Outside drain collection or
Agitation during wastewater
Box covers
unction boxes
conveyence
End of drainpipes at lagoon
Agitation during wastewater
Extend discharge point of pipes underneath
conveyence
ia2oon liquid level
Lagoon Surfaces
Volitile gas emissions,
Proper lagoon liquid capacity
Biological Mixing,
Correct lagoon startup procedures
Agitation
Minimum surface area- to -volume ratio
Minimum agitation when pumping.-.
Mechanical aeration
Proven biological additives
ANSONCOUNTY, NC

BROWN' EEK Soil Witcr Coisservatitm District
USDA Natural Resources Conservatloi lice
Odor Control Checklist - Swine continued
Irrigation sprinkler nozzles
Nigh pressure agitation
Irrigate on dry days with little or no wind
Wind drift
Minimum operating pressure_
Pump intake near lagoon liquid surface__
Pump from second-sta a lagoon
Storage tank or basin
Microbial decomposition
Bottom or midlevel loading
surface
Mixing while filling
Tank covers,Basin surface mats of solids
A itation while emptying
Proven biological additives or oxidants
Settling basin surface
Microbial decomposition
Extend drainpipe outlets underneath
Mixing while filling
liquid level
Agitation while emptying
Remove settled solids regularly
Manure, slurry or sludge
Agitation when spreading
Soil injection of slurry/sludges
spreader outlets
Volitile gas emmissions
Washdown spreader after use
Proven biological additives or oxidants
Uncovered manure, slurry
Volitile gas emissions
Soil injection of slurry/sludges
or sludge on field surfaces
while drying
Soil incorporation within 48 hours
Spread in thin uniform layers for rapid drying
Proven biological additives or oxidants
Dead Animals
Carcass decomposition
Proper disposition of carcases (see mortality
management)
Dead animal disposal pits
Carcass decomposition
Complete covering of carcasses in pits, proper
location/construction of disposal pits
Incineration
Incomplete combustion
Secondary stack burners
Standing water around
Improper drainage,
Grade and landscape so that water drains
facilities
Microbial decomposition of
away from facilities
organic matter
Manure tracked onto public
Poorly maintained access
Farm access road maintenance
roads from farm access
roads
. I )• a j;n'' i Sy '. y."V�.�n -. P
`��-.7y'Cy q� ,vim
•i! ri{���: ��: 'rll ff.:-"rfs•ieFLah. s'rl�{rr:`Y*i'x lfaF. '.31i�a1
i+ l,� 55 r 1,.• `r�,.5{�� �� { rh* `€ i . `.�F
7-.�3&�'+i"•'(
nT..�,r '1i,5•. . R.: •f!-a ',`••i^!f'�::. i'• fiF"YtiJir�.�..{1 �•r'S:`ST��M....
1' ' .? ,. F YI:J ' =' h.->,.p
`[y7�:• ,�P��`[]. S j 1€!'r.�1q{�' y, &�,�1.
�I }TI��Ii ,'��L7��i'7"1M�hPA'rh`�i?',
.; ,,.. s { :,. - •'fir{'tr �,�',�n rs'<P:. ;, t' Tl � F �,J+ 1s�F v' `' - a i �- . �'�;y�, _ - x.,,�iic n - ;�. . �} � "'M .I � r}�i��r u M � `� �� �: ��' 3- ,, ,� , r' : �1 � �
IsJr1 �'���-'.���
j�iY ._.>: w,ye .i. .,�. '{•�E- .. ';r.iF
_E tE' [ -_. �r r : ] Ij,"-q, �r II f Sa ��.i��
„o-.. t) -'-, t { 1t `[,_,. t,5fi Jl..
'?r. 7'g�A � ��
s' r -.P.l'a'r,.•
r '•...'{ � 14' �P ';uyr':�q-[°3+ G r ,�..;.o-'7 Y�.^`.L_ } 'x � •`�€Yi i i SK 'aid. '4- f .rr ,b..: >4,�, E-:�}�3€`? �'�F
�� .� •N 75"r� � �e�k
• lbw ty � :r� '. A..y' f,},.t �GS•4'SC;Ai l i ��` J • 6 '" ^Y F �� � 1���[ Y! ''��1L.`iI �T :�s. !Q4 'l �i€1'�i A "[' �/I�.- N � ` f k'b♦ � , F.if � �[, �€.
�'�l '� 1. F�€ € �, ^fV . ' "Jf ��1•i •i � �i �i � 1. ai'•A Y'}?f;' .q. Yn � S�. � ..i e'F r t �E' ,
-�`F`d��'y r 3! .e :t'e r'71:`5rr. n ,„,W ,r I 1'J 'ib:L
}Jirr s� l^+^ f _e..'�.y{,jN`' f`,gdr .iai+ .. 4 v(.`
7 y,"'1"' 1''_i n ��¢�`� ~ {{,y7 [ 7'�,tTMp [" {} .:' ��!�:
` € 1 � k4t s ...�Y���- I r at �,1:
! rf•. I�1'• "a-r."'.'rip,••l ,.'yr 1,... e , 41...'�r
�:.
'k[{, k f '�! �`. _
i�� " _
. cr:. I .A,,;{ { r ! e I t r S { " � •� s .r^ ., 'J ir' � �y i � s� �S'� � � r�. it •
" e •� q � tt J y:
' }' S P £• _ l i { 5 2' 1' ;5 y♦T y+ ifi7� P`yyi "E r ( "l� .11
`.�' I�•�
.�f ��
f3 i. '.r'+-'. [ I r_f.i,,:'{' i 4 nryz{,{ r:'• F' -{ {'-.,: '# :• r-';,• .�' r+l:"' akt•7yc
. � �4F �I S tE f �S,-�EIkgF3� t,N i �'M�s�� irRl r�� f:.l'a,,• _ _� .a q � i, b� ^'�H 'EJ Y.y-'i�� � i, ff� a:
Y xl:FS-�+#L1�411{51-k1Y,ij {ii ;•li,ri.F^iT?��1,%SF �i. ��.., 1. ltl ffr�r114 �_: :?'C� .S.!' 1 �{ ��'t�.�151i $�1!'.. 1 ri`-..t°S�.i, �•
a"a:. F' t>>:i`: r�. r ,j'�� i� � g �. r��S s`J? i � rJ . p -:� .•�. _ ' n` '� y - ,�i> k �e E �'�- .F� r�%,Ic ;r�.��� ; �� I 1 -��i
f �. - t"" ��X. [..�{?-,:§:: .,€ ;�,�Y E •JI ! i •'�� :.lt ^ `S=li i s t� T i'� �F E Il � e h� � p�4i;1 m �,i 4;�€ � l•9 '1, �;
-'�'{ r sly „' Ei it b kV"yF ¢. ;:•t `ij(� 4 '•r{;�: - i . �q $ r � d('y I , I g:: °fJ(,��€� a R'r. '. e � 3dy qF • f .^,fie ��!rr`� • i ;:S '1�1 � _6 �1'
r ,
ii" 'l:ri S'. 3ki6s, 1J - ": �,,�!Ii S,.kt}} i :•' C' Nsf� #'+F l-. `rl.-�k, lY�y _�_3�y']i�t "!i., -.PL•
�-'Ed ��� "^Ji iI��1�S�`
�� I. g Y,<, �. h"' -�I' '-d- m'b .ems' � g. �n-r•€y! ��,;:, t ;� `?�` ! b, ,>S�
''>I��{l f� �r %1'�i ILr^ :ig. 'ii' r'ra4q�n ri
1 r'
MATH
:41�ru f�a sal p iw + it r{I��.tls n�� c i iii:!L�ia'• - ��' i t' ` I�
,. L•,. ".�y, . 1i.A�
,,l N.S`ON COUNTY, NC

BROWN CREEK Soil Water Conservation District USDA Natural Resources Conservation Service
Huntley -Vernon Farms Inc - OPERATION AND MAINTENANCE PLAN UPDATE
This structure is designed to operate as an anerobic lagoon, with waste treatment and 180 days of temporary
storage. Time required for the fluid level to fill from STOP pump elevation to START pump elevation may vary
due to site conditions, weather, flushing operations, and the amount of fresh water added to the system.
The 180 day temporary storage in this structure consists of: 1.) waste generated by confined animals; and,
2.) excess rainfall after evaporation (5" for Anson County). Additionally the structure can store the 25 year-
24 hour storm (6.3" for Anson County) above the START pump elevation. The volume of waste generated by
3552 confined swine remains fairly constant throughout the year and from year to year. Excess
rainfall will vary from year to year. The 25 year rainfall is not considered in the annual pumping cycle...
this volume above the START pump elevation must be maintained and available.
The START pump or maximum normal operating fluid level is usually the outlet invert of pipe(s) from the
confinement building(s). If the outlet pipe(s) is not installed at the START pump elevation, a permanent
marker must be installed at this elevation. A STOP pump elevation must also be established to maintain
lagoon treatment depth and volume. Pumping can be started or stopped at any time between these two
elevations to land apply waste without runoff or leaching, and accommodate weather, soils, crop, equipment,
and management situations.
Land application is an accepted method of liquid waste disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation; honey wagon application is a more labor intensive/time
consuming method. Be careful when applying waste to prevent damage to crops.
IMPORTANT ITEMS
1. Fresh water should not be used for flushing... recycle from the anerobic lagoon.
2. The approved waste utilization plan shall be followed. This plan recommends sampling and testing of
waste prior to land application.
3. START pumping temporary storage when fluid level reaches elevation 98.2 (or before). STOP pumping
when fluid level reaches elevation 96A. This temporary storage, less 25yr-24 hour storm (volume to pump)
is 38585 cubic feet (288616 gallons) every 180 days .... 77170 cubic feet (577232 gallons) per year.
4. Refer to the approved Waste Utilization Plan for important information on irrigating liquid waste —
application rates, maximum application amounts per irrigation and rest period between irrigation,
5. Keep vegetation on the embankment and areas adjacent to the lagoon mowed annually. Vegetation
should be fertilized to maintain a vigorous stand. Keep grazing livestock off all embankment areas.
6. Repair any eroded areas or areas damaged by rodents and establish in vegetation.
7, Keep all surface runoff diverted from the lagoon to stable outlets.
8. Keep a minimum 25 foot buffer area around waste utilization fields adjacent to perennial streams. Do
not apply waste in open ditches or water courses, within 100 feet of a well or within 200 feet of a residence
9. Maintain a copy of the approved Waste Management Plan on farm (or at the confined animal facility)
at all times. The Clean Water Act of 1977 prohibits the discharge of pollutants into waters of the United
States. The NC Department of Environment, Health, and Natural Resources- Division of Water Quality
is the responsible for enforcing this law.
1/16/01
ANSON COUNTY, NC

Mortali
Burial three feet beneath the surface of the ground within 24 hours after
knowledge of death. Burial must be at least 300 feet from any flowing
stream or public water body.
ix rM-. :- r. .:
r . - - Incineration
Dead Poultry Only — placing in a disposal pit. Size and design of pit
approved by the NC Department of Agriculture.
Any method approved by the NC State Veterinarian which involves
possible salvage of part of a dead animal's value without endangering
human or animal health. (Written approval of the State Veterinarian
must be attached.

Huntley -Vernon Farms Inc
Phone Numbers
1MPORTANTM
Implement this plan if any part of the waste management system for this operation fails
or results in overapplication of waste, or discharge of waste to the waters of North Carolina!
DO NOT WAIT or PROCRASTINATE if there is a problem! Make every effort to ensure
that animal waste does not reach surface waters... or neighboring property!!!
This plan should be posted and accessible to all persons involved in the day-to-day
operation of this facility!!!
Post in a Prominent Place!!!
USDA-NRCS
BROWN CREEK SWCD
Anson County NC

r
Huntley -Vernon Farms Inc
1. Stop the release of wastes Depending on the situation, this may or may not be possible. Suggested
actions are listed below.
Lagoon Overflow
Add soil material to increase elevation of embankment Call a pumping contractor
Pump waste to fields at an accceptable rate Make sure no surface water is entering lagoon
Stop all flows into lagoon immediatley
Runoff of Field Applied Waste
Immediately stop waste application Evaluate and eliminate reason(s) for runoff
Contain waste in a temporary diversion - Evaluate application rate for fields where runoff occured
Incorporate waste to prevent runoff
Leakage from Pipes, Pumps and Sprinklers
Stop recycle pump Close valves on leaking pipes to eliminate discharge
Stop irrigation pump Repair all leaks prior to restarting pumps
Leakage from Flush Systems, Houses, Solid Separators
Stop recycle pump
Stop irrigation pump
Stop all flows in house, flush systems, solid separators
Repair all leaks prior to restarting pumps
Make sure no siphon occures
Leakage from Base or Sidewall of Lagoon... often seepage as opposed to flowing leaks
Dig a small sump or ditch to safely catch seepage, install subersible pump, pump seepage back into structure
If seepage is cased by burrowing animals, trap and remove animals, compact clay soil material in holes
Have a professional evaluate the condition as soon as possible
2. Assess the extent of problem and record obvious damages.
Did waste reach any surface waters? Could spilled waste reach surface waters?
Estimate volume of waste released and duration of event Could a rain event cause waste to reach surface waters?
Note Damage... employee injury, fish kills, property damage Are potable wells endangered (on or off property)?
Did spilled waste leave the property? Estimate how much waste reached surface waters
3. Contact appropriate agencies. See numbers posted on front of this plan.
Call the DWQ (Division of Water Quality)... Regional Office or After Hours Emergency number
Have the following information ready. Your name, facility, telephone number, details from Item 2 above,
exact location of facility, direction of movement of spill, weathertwind
conditions, corrective measures taken, seriousness of situation
Call local EMS phone number if spill leaves property or enters surface waters... instruct EMS to contact Health Department
Contact local SWCD-NRCS Office for adviceltechnical assistance (also may want to contact Extension Service Office)
4. if none of 3 above works
Call 911 or Sherrifs Department, explain situation and ask personnel to contact the proper agencies.
5. Contact the Contractor of your choice to begin repair of problem to minimize off -site damage.
Contractcr Name:
Phone:
6. Contact the Techical Specialist who certified the structure (NRCS, Consulting Engineer, etc.).
Technical Specialist: R Lin Taylor Work Phone: [phone]
7, implement procedures as advised by DWQ and technical assistance agencies to rectify damage, repair
system and reassess the waste management plan to ensure no -future release of waste.
Post in a Prominent Place!!!
USDA-NRCS
BROWN CREEK SWCD
Anson County NC

i �oF W q
'O G
>_
fl ,c
Travis McRae Lookabill
Gold Creek Farms # 2
P.O. Box 954
Wadesboro, NC 28170
Dear Travis McRae Lookabill:
Michael F. Easley, Governor
William G. Ross Jr,, Secretary
North Carolina Department of Environment and Natural Resources
February 28, 2005
Alan W. Klimek, P.E. Director
Division of Water Quality
RECEIVED
FEB 2 4 2005
ON - FAYE INUE REGIONAL OFFICE
Subject: Certificate of Coverage No. AWSO40009
Gold Creek Farms # 2
Swine Waste Collection, Treatment,
Storage and Application System
Anson County
In accordance with your Notification of Change of Ownership received on February 11, 2005, we are
hereby forwarding to you this Certificate of Coverage (COC) issued to Travis McRae Lookabill,
authorizing the operation of the subject animal waste collection, treatment, storage and Iand application
system in accordance with General Permit AWG100000.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Gold Creek Farms # 2, located in Anson County, with an animal capacity of no
greater than an annual average of 3552 Wean to Feeder swine and the application to land as specified
in the facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to Wean or
Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are unneccessary,
they may be replaced by an equivalent number of sows. Any of the sows may be replaced by gilts at a
rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009, and shall hereby void
Certificate of Coverage Number AWSO40009 dated October 1, 2004. Pursuant to this COC, you are
authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Since this is a revised State
General Permit, it contains new requirements in addition to most of the conditions contained in the
previous State General Permit. Enclosed for your convenience is a package containing the new and
revised forms used for record keeping and reporting. Please pay careful attention to the record keeping
and monitoring conditions in this permit.
If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new Waste Utilization Plan developed.
tia
Carolina
ura!!y
Aquifer Protection Section 1636 Mail Service Center Raleigh, NC 27699-1636
Internet: htip :Nh2o.enr.state.nc.us 2728 Capital Boulevard Raleigh, NC 27604
An Equal opportunitylAffirmaWe Action Employer— 50% Recydedl10% Post Consumer Paper
Phone [phone] Customer Service
Fax [phone]
Fax [phone]

I
f
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
laws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 2H .0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100 foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terns and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Aquifer Protection Staff may be reached at [phone]. If you need additional information
concerning this COC or the General Permit, please contact J R Joshi at [phone].
Sincerely,
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
,%Eayetteville-Regional-Office;-Aquifer_ Prote`ctio`ri`S ection
Anson County Health Department
Anson County Soil and Water Conservation District
APS Central Files Permit File AWSO40009
AFO Files

o�oF wArFg%
Huntley-Vemon Farms Inc
Huntley-Vemon Farms Inc
PO Box 588
Wadesboro NC 28170
Dear Huntley -Vernon Farms Inc:
Michael F. Easley, Govemor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
October 1, 2004
Alan W. Klimek, P. E., Director
Division of Water Quality
RECEIVED
OCT 15 2004
DENR - FAYETEMLLE REGIONAL URGE
Subject: Certificate of Coverage No. AWSO40009
Huntley -Vernon Farms Inc
Swine Waste Collection, Treatment,
Storage and Application System
Anson County
On June 11, 2004, the North Carolina Division of Water Quality (Division) issued a revised State General
Permit for swine facilities. The General Permit was issued in accordance with the directive of Senate Bill
733 (Session Law 2003-28).
In accordance with your application received on January 27, 2003 and in accordance with the directive of
Senate Bill 733, we are hereby forwarding to you this Certificate of Coverage (COC) issued to Huntley -
Vernon Farms Inc, authorizing the operation of the subject animal waste collection, treatment, storage and
land application system in accordance with General Permit AWG100000. The issuance of this COC
supercedes and terminates your previous COC Number AWSO40009 which expires October 1, 2004.
This approval shall consist of the operation of this system including, but not limited to, the management
of animal waste from the Huntley-Vemon Farms Inc, located in Anson County, with an animal capacity
of no greater than an annual average of 3552 Wean to Feeder swine and the application to land as
specified in the facility's Certified Animal Waste Management Plan (CAWMP). If this is a Farrow to
Wean or Farrow to Feeder operation, there may also be one boar for each 15 sows. Where boars are
unneccessary, they may be replaced by an equivalent number of sows. Any of the sows may be replaced
by gilts at a rate of 4 gilts for every 3 sows
The COC shall be effective from the date of issuance until September 30, 2009. Pursuant to this COC,
you are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC. An adequate system for collecting
and maintaining the required monitoring data and operational information must be established for this
facility. Any increase in waste production greater than the certified design capacity or increase in number
of animals authorized by this COC (as provided above) will require a modification to the CAWMP and
this COC and must be completed prior to actual increase in either wastewater flow or number of animals.
Please carefully read this COC and the enclosed State General Permit. Since this is a revised State
General Permit, it contains new requirements in addition to most of the conditions contained in the
previous State General Permit. Enclosed for your convenience is a package containing the new and
revised forms used for record keeping and reporting. Please pay careful attention to the record keeping
and monitoring conditions in this permit.
Aquifer Protection Section — Animal Feeding Operations Unit
1636 Mail Service Center, Raleigh, North Carolina 27699-1638
Phone: [phone] FAX: [phone] / Internet: h2o.enr.state.nc.us
An Equal OpportunitylAf iirmative Action Employer — 50% Recycled110% Post Consumer Paper
NorthCarolina
Natu.naffil

If your Waste Utilization Plan has been developed based on site specific information, careful evaluation
of future samples is necessary. Should your records show that the current Waste Utilization Plan is
inaccurate you will need to have a new.Waste Utilization Plan developed.
The issuance of this COC does not excuse the Permittee from the obligation to comply with all applicable
Iaws, rules, standards, and ordinances (local, state, and federal), nor does issuance of a COC to operate
under this permit convey any property rights in either real or personal property.
Upon abandonment or depopulation for a period of four years or more, the Permittee must submit
documentation to the Division demonstrating that all current NRCS standards are met prior to restocking
of the facility.
Per 15A NCAC 2H .0225(c) a compliance boundary is provided for the facility and no new water supply
wells shall be constructed within the compliance boundary. Per NRCS standards a 100 foot separation
shall be maintained between water supply wells and any lagoon, storage pond, or any wetted area of a
spray field.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
If you wish to continue the activity permitted under the General Permit after the expiration date of the
General Permit, an application for renewal must be filed at least 180 days prior to expiration.
This COC is not automatically transferable. A name/ownership change application must be submitted to
the Division prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual permit by contacting the staff member listed below for information on this
process. Unless such a request is made within 30 days, this COC shall be final and binding.
This facility is located in a county covered by our Fayetteville Regional Office. The Regional Office
Water Quality Staff may be reached at [phone]. If you need additional information concerning
this COC or the General Permit, please contact Duane Leith at [phone].
Sincerely,
for Alan W. Klimek, P.E.
Enclosures (General Permit AWG100000)
cc: (Certificate of Coverage only for all cc's)
Fayetteville Regional Office, Aquifer Protection Section
Anson County Health Department
Anson County Soil and Water Conservation District
Permit File AW SO40009
APS Central Files

September 23, 2004
Mr. Stephen A. Barnhardt
N C Division of Water Quality
225 Green St.
Suite 714
Fayetteville, N C 28301
Mr. Barnhardt:
RECEIVED
SEP 2 9 2004
OW - FAYEf MLLE REGIONAL OFRCE
In response to your letter of September 17, 2004, I would like to offer the following
explanation of the violation that occurred at Huntley -Vernon Farms, Inc. on September
10, 2004.
(1) On September 5 we had 25" of freeboard at our farm;
(2) We received 9.8" of rain from September 6ah through September 8th
(3) On September 9th I inspected the facility and it appeared we were right at 19" of
freeboard; however the visual inspection must have been wrong;
(4) In addition, sometime early on 9110 the on site farm manager, without thinking,
flushed the houses, putting additional pressure on the freeboard; I had not had the
opportunity on the loth to visit the farm prior to Ms. Cramer's visit
In the future we intend to take the following steps to insure there is not a reoccurrence of
this problem:
(1) Manage the lagoon level more aggressively during the drier summer months to where
we are managing it from the "stop pumping" level to the "start pumping" level and
not above;
(2) Monitor freeboard levels more aggressively during heavy rain events; and
(3) Delay flushing houses during times of freeboard stress if necessary.
(4) Immediately inform the DWQ if freeboard levels are below the required 19"
Thank you for any consideration you can give us on this matter. We will take the steps
outlined above to do our best to keep any further violation from occurring.
Jack Vernon
OIC
Huntley -Vernon Farms, Inc.

CREEK Soil Wacer Conser, n Discricc US latural Resources Conservation Service
WASTE UTILIZATION PLAN.
Waste Utilization Plan
Name of Operation:
Huntley -Vernon Farms Inc
Owner/Manager Agreement
I (we) understand and will follow and implement the specifications and the operation and main-
tenance procedures established in the approved animal waste utilization plan for the farm named
above. I.(we) know that any expansion to the existing design capacity of the waste treatment
and storage system, or construction of new facilities will require a new certification to be sub-
mitted to the North. Carolina Division of Water Quality (NCDWQ) before new animals are stocked.
(we) also understand that there must be no discharge of animal waste from this system to surface
waters of North Carolina from a storm event less than the 25-year, 24-hour storm, The approved
plan will be fled on -site at the farm office and at the Brown Creek Soil & Water Conservation
District office in Wadesboro, NC. The plan will be available for review by NCDWQ upon request.
Facility Owner
Z"C. Date:
Huntley -Vernon Fauns Inc
Facility Manager
(if different from owner)
Date:
Person Preparing Plan CLIA')
/Date:
R. Lin Taylor
Affiliation: USDA -Natural Resources Conservation Service
1706 Morven Road
Wadesbgro, NC 2BI70-3142
Page 7 ANSON COUNTY NC

�{•.���
�; ` µ`y:*�'•►.!• tiro •� ��" �!I' Ir til �a,i. `irk ,.
'y., � 'i�24ati � +��r? •1J.. �f tt YY�^�� �� + W }ti L, ! 5 `I � .�
:K ` 1 � ;�'r'�s�, .�4`, ��r•,}R f � 1 `*. .•yt1 {�"+_''„ 1 5 � w x�. ,'�`. f �{'�•
J ~ �IJr'r�F1!�i :! ��?. •', ���'L{ti�Ll jt,�;••7+. :� w..,, � .,"i+ mot,`,' }, .i -}. .s r '� Cw �e' �1
Jr-�r l.F•'' 1 "'i 3 i►f' " �L -•
ai[y}'.rr'=,,i. :ram ..'�•+,5� ��i��1�. r -_:� '•. f �' � r,iv�' +�' 4,Y. '1
S Jr Y -' � f ,''F\�'�w'{`1 4�,V l 7�. ,, ,�'�.�',�► � � � V "fit . ; f l _ -
r� e{ny V ►1+ ��,.r r r O I
•!'i.;V•t yi!r i `� CC � Q w �""``S.rw •r 11►"Y-Y 1 �K' r� • ��'1� :! — � I i ��'•
FYI
i. it`�•rt�w�it1�i '�.y -ti.'.1 ;- n „f rK+�•_ ... ,�C' / ) I
If Z # #
'vim ` � y^� Z C U �; 1'' 1 ,, 'v''.'t:.�►•,� •��►' .4 �+ � »� , 1 YrF. �{ .. `
��•'fy� �iry a r �t r �•. `� t5 n b�jr."'
ff s _• L!.. R .-.., I
ra .•afy �-. � �.,;' � ♦ ,,��`.�• f{��y�,(a'�,Ly�I �.�``-'i / iJ C\l J + ./ i� ' er,' �� �� � � ., � `•+
IF
41
qd
. .+ _� 4 �,'• ff�,h ;,•�]' ��y��` r �• y ,,r'r 1 Y. \il' 1��r 1r-"' ��'`. �', _' =.4 t"'(' � f-1 �:.�.,
''1,�ry.�, �� �, {r�r� .•�i' I.f� hr , '.• ✓ r� rG. �'' �' •j i�2.•
OF
IL
V1d
-�70. // �~ ^{''u�F•1 � � '' �, .� • t� �• ^�.''1_ W� I5 �`,�.,y�y�i•.. +1 1' i IY .�9[�,., � •► `11
�� ��' .v• .. �' tlltl _ , ;r - rip—,
� h •"
a h h �� s� ' � y,,. tt r'i - y.a , 42 4 t �'i • •r` .1�-ln;�..'`C'"-� �,�„� ~ . i
'• w',
,rty1—t r f (�7.;� tom. ,"• !�i r�� ~TJ � �� ' '�+` r��J ��1 : e •, �+' • � . �.�
f '�. ')/ WWW ./"C�y� _ ,�rw �• ^ N,
.. yf••••.l �+y f �' ` '•J, `I °' {t,�'•.+�"'7"'... .�• �-a.:, \ �;` f•1�y i•' .. _
A" r n wq, R] .2 a `(v ij/ ... •�a. ., •��`w.• .\ '.tip= '�
'_ w:1'•� .� _ �, � R � W v� �•'�_ �'• din^ . ^isi .�U Q . � �. �, r_�.•• f J
,�• z. ..�: '�•��.r" �.�, tea• "„��,. ..,. � a �','''• c��
A`l� •0' 'iic �l , '.��, -••il ..t 'Qlf* �i', )r ,.I. *,ptl. q• �• ! .J,�. r �'� "�� � `` /��'l�� �'.Y"' x. l•. _'�;
'• bw .:•e�.:; '[�f•3 , r\,�i.Y �:i: �"` y L�•O •f+ . .F. '�' ���� I i� µif �.S.l�J�1r
`1"Al • atr '', .`i N pU \u " .. a "' ','; �:, \ ( t3 .•J '
• f �. , �' a .: ,. ' `�' f , �J'; -
Ty
IA
., `.• �_ '�i ti �.,,,•� . t}h ' �_' = !,.\.` / tit �..: ;,.' ...
IV
/r}+;!1 ,� ���.'. � . ;`i•'•,� 'a!�, .�,.° •L . a �..:'.' ,�;��y„�Ll#':'r�'. ',"�. e'.-i'.r �(�' �, /) ' �` �(+ , � ) �k •', Cr �,�' •�r� LTy
t }r ... i• >,`��; .\r• �: �,'� �t ��: ..�.r.^"��` �-^^r,•.. .�:Y ti.. /,'A .W� `• � Y. � '!rY �} r:`.• "t.y'.+•
1 ,5' �1w �k '•1 -r� �•` �v�" '`�' .R � •,,:;�' _ �t• ��... ! .NNN7 � - M'•�� �1,�`S4�
',rftF � �._ .. - .I•• •^ -.-_ ,. ». „,j ��' , S',•��{E•�'INi \ v � ;ram. ��

JANUARY 20, 1998
MR. KERR T. STEVENS, REGIONAL SUPERVISOR
STATE OF NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
FAYETTEVILLE REGIONAL OFFICE
225 GREEN ST. SUITE 714
FAYETTEVILLE, N.C. 28301-5043
MR. STEVENS:
iI
J ,y 2 2 1998
REG p�tLLE
OFFICE
IN RESPONSE TO YOUR NOTICE OF JANUARY 7, 1998, PLEASE NOTE THE
FOLLOWING:
1) THE LAGOON WILL BE PUMPED TO SPECIFIED LEVELS AS SOON
AS THE WEATHER PERMITS. EQUIPMENT FOR PUMPING THE
LAGOON WAS ON SITE AT THE TIME OF YOUR VISIT AND, AS YOU
ARE AWARE, WE HAVE RECEIVED UNUSUAL AMOUNTS OF
RAINFALL FOR THE PAST COUPLE OF MONTHS. PLEASE BE ASSURED
WE ARE MONITORING THE LAGOON LEVEL AND PUMPING WITHIN
THE PROCEDURES AS MUCH AS THE WEATHER HAS ALLOWED,
2) I APOLOGIZE FOR THE IRRIGATION RECORDS AND WASTE
MANAGEMENT PLAN NOT BEING ON SITE AT THE TIME OF YOUR
VISIT. WE WERE IN THE PROCESS OF INSTALLING A SET
IRRIGATION SYSTEM AND THE SOIL CONSERVATIONIST WAS
UPDATING OUR PLAN IN ACCORDANCE WITH THE NEW SYSTEM.
THE PLAN WAS BEING RETURNED FOR HIS SIGNATURE ON THE
DAY OF YOUR VISIT. ALL PERTINENT RECORDS WERE IN ONE
FOLDER. WE WILL PREVENT THIS FROM HAPPENING IN THE
FUTURE. IT IS OUR PRACTICE TO HAVE THIS FOLDER ON THE FARM
AT ALL TIMES.

I AM ENCLOSING A COPY OF THE PLAN AND OF THE IRRIGATION RECORDS
FOR YOUR REVIEW WITH THIS CORRESPONDENCE. IF ANY FURTHER
INFORMATION NEEDS TO BE SUPPLIED PLEASE LET ME KNOW.
7S.
LY,
VERNON
SECRETARY
HUNTLEY-VERNON FARMS, INC.

i 'BROWN CREEK Soil Water Conservation District USDA Hamra Resources Conserva8on Service
WASTE UTILIZATION PLAN
Waste Utilization Plan
Name of Operation:
Facility Owner
Facility Manager
(f different from owner)
Huntley -Vernon Farms Inc Swine Farm ..
Anj
Huntley Vernon Farms Inc
_ Date- Z -//'g?
Date:
Person Preparing Plan / 1
L. Date.- 1
Rob4rrt E. fiorton J
Afllation: USM Natural Resources Conservation Service
1706 Morven Road
Wadesboro, NC 28170-3142
END
Paae 7 Am-gr)rr c_nryN ry Mr

c, K,y:.r•.t...^,�;•..^.`:/:L►��r.ti`Mti.'�1► t .�. � Y • � u + ,���' 'twr � •'��1,;
lk r %
'i ; G"�{ti,.,� �`(1%aY.�r�'�i"M •�f •r-" `• �U. ' y _ � ` ` }„' 't�vY � 1 ,� 'f,• !r�' / +
.j�•\ ti t.X `++'I t+Ev =7'•• ►. •,L "r. .fir. 1... ti
1/�L.I�,L,�_.•-�Ts'' l ''L a e 4 , +.''°4•.y ,. �f
Ji[•1 tti'1(cr
r ,no-i`,^�l�"�' .� '�a,e�l� �F'.`�. },+� .jr;, .+ • •/ Q f 1•�y,,,
�� � �y.rai �� ►� �f��l7rT',ir_, +Sa .1:.,77�� � �1 � •rV t� •�! �. f � '
�.�'1y •Y�'y�wy L `r
r•'• fy:Y`�*�'!:•S i LC O d "•�Lir� •I~� +�'\ 'Y h^�•r !,`r'• f �� �••r."`•• %+
C C'.. O „ y 'I y I+ i 'K'A• ••i."L N• ''i•S �t lT+' �'J! •(►.
rr ,r +itx • w N m
X E-
a rc ,.., :�.;' ,1, ,� .r-,,r we ... ',•' -K•'
,% M Lsi lt. �' • (rt�y, _ILL. i , y� /�G 1 C) j , ln: \ • tiT a r
1r'.,y� tv �"�i�rti •'Y�r��. >`� ,:�•.1
w _ X
41
r. 1- [" � � tom• 1�°�' � �' L r \l. � Lr, 1. �� �.�� �' �
� r. rh +L• 'r i �w;*'•i In � �. � 1 .�
�Yr.'��:}V SFr' �' � +::�.' '�'' Y /S i��yr' • aG." •:,'� •\ ����:
/Qy �% i.ar •j{'Si'!\3'1!, •.!I: 5 Y' ^ ..�� • fl,f ^r{. •+ice, .'...r: �U•.�tf a„
v P�l�tyt Y:�, � !��'.; �r>�la � �vx ''• s •r 1` rt _ ,� ���j �• � '� .M
Jlfia� '� ��. j-�, � f�l•y{�_ ({0 t' f.�.. n � �r rjr''i",- "Lit." y •'
�n`'N,' �.r "'•. u.. .ra \l' `Q �Z r Vr C9 _ - - -!Tr-
f'• l r i I Vi � •; •' ��r.•k �+ .i ,•yam :' 'Y.+•• f1 '•J i'•.
••W _•' � -r' �>` .fie MIt,� � ;�,'• ti I�rl.. ..•,:• •n t� � d 1♦ N �•a. .'�(',4.
�.�, �. •L. �"}�+�;;y `N, .!
ic
+. • 1 i i +, Oc 'j , _' j� r►� +`�i ♦ \y' ' ~
1= .t• :. 1 ,�. �. •3 i��+'`t�►'k,'.,,',' �' �f '� \OV i••.. 7 L�f Q }1 1 'r�• + Kr r'
;, .y.•`�. '.� ��' '•�; '..+sty• 'ny'�•:,\'' r..,. f'•� •'-! •ti�''L'�;
•Y;.;► + :livr.�'r: f D T,• 1+1�' �� �.. I •W�l d• , ti; . ,.{.� �! . •?�1-i}`�t / y5 � ��
'$` `•_- '! 'L' ya �Lw. Q • .7� \y `+. ate.
.i� \,}/ �\ih ,� f ' •t.%�' �� , t ,i+: �� •� '^ �,r A..`/'� �Rr ```Ke. [��•� 7•[{rj��' Cl' (� y,i" •r,c •'�1{,.�j'4 '.�(�a .T. •� 7�Y _ .,,• .j +.�♦ t � ii•3'•►i�� ��' +-..� rl,,,; '•�l>~l�:`r�'•'�' � 1'rrr !}. 7_•y,i•'~ S 'srii. .�7 :� u �r�'�y_,!�•`�F�
�/i..rt�y���• F• `) 11�,Fy1�•►,�'�••L4'�\r;"���,j• ,,y`'�/.`�*{��� ,�' -� ~����,•�i+:,�• ♦.�F�" A��� ;:�i✓ �plt" f `rS�L., h.}`~F t i- y�~[—�'..�,•,,,�^
••L K^',y' J!'� .ri � `•�•s �' , �'� � 1 '� •_.w•r `'.. ... `. I � '�.' _ ' .. 1 �t ��L.. 1 `� �.T y1�

BROWN CREEK Soil Rater Conservation District USDA Natural Resources Conservation service
WASTE UTILIZATION PLAN
Sludge:
This waste utilization plan must contain provisions for periodic land application of sludge at agronomic
rates_ Sludge will be nutrient rich and require precautionary measures to prevent over application
Broadcast Soil Incorporated
Estimated Annual PAN fmin Sludge: 270 lbs. N 320 lbs. N
Syr Sludge Accumulation: 1350 lbs. N 9598 lbs. N
Based on a 5 year sludge removal schedule. estimated land area required for sludge disposal is:
7.5 acres of grass asQd on an appliotfon rate of 180 lbs. N per acre
20.0 acres of com/soybeans based on an application rate of 80 lbs, N per arm
All the above figures are only estimates_ Actual PAN and land area needed could vary 25% or more depending
on sludge nutrient analysis. soil types. crop. realistic yield. and application method. Likewise. sludge
disposal on a schedule other than every 5 years would drastically alter these estimates
Contact your technical specialist at the BROWN CRi EK Soil & Water Conservation District - Natural
Resources Conservation Service (formerty the soil conservation service) Office in Wadesboro, (704)
694-2710, when you receive a waste analysis report. Request assistance calculating
allowable application rates and amounts prior to,applying waste.
Figures provided are estimates of waste production —excess wash water or run -oil (d any) may increase waste volume.
Operation constructed to NRCS design and specs, and certified (0.200) 1/95. Acreage estimates and
irrigation parameters provided for underground main/hydrant irriciation system design. Actual acres irrigated
will be determined by final design. Field acres in this plan are best estimates. _
Nate: Presently waste irrigation equipment is rented/contracted on "as needed" basis.
Paae 4 11ucnV f�nrrnrrry sJr

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
Michael F. Easley, Governor
William G. Ross, Jr., Secretary
Kerr T. Stevens, Director
HUNTLEY-VERNON FARMS INC
112 WILLIAMSBURG LANE
WADESBORO NC 28170
Dear Huntley -Vernon Farms, Inc.:
i ifflo."FA
•
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
January 29, 2001 1 V Lu
FEB 7 2001
0-EJ1l-LE
Subject: Certificate of Coverage No. AWSO40009
Huntley -Vernon Farms Inc
Swine Waste Collection, Treatment,
Storage and Application System
Anson County
In accordance with your application received on November 30, 2000, we are forwarding this Certificate
of Coverage (COC) issued to Huntley -Vernon Farms Inc, authorizing the operation of the subject
animal waste collection, treatment, storage and land application system in accordance with General
Permit AWG100000. This approval shall consist of the operation of this system including, but not
limited to, the management of animal waste from the Huntley -Vernon Farms Inc, located in Anson
County, with an animal capacity of no greater than 3552 Wean to Feeder and the application to land as
specified in the Certified Animal Waste Management Plan (CAWMP).
The COC shall be effective from the date of issuance until April 30, 2003. Pursuant to this COC, you
are authorized and required to operate the system in conformity with the conditions and limitations as
specified in the General Permit, the facility's CAWMP, and this COC, with no discharge of wastes to
surface waters. An adequate system for collecting and maintaining the required monitoring data and
operational information must be established for this farm. Any increase in waste production greater than
the certified design capacity or increase in number of stocked animals above the number authorized by
this COC will require a modification to the CAWMP and this COC and shall be completed prior to
actual increase in either wastewater flow or number of animals.
Please be advised that any violation of the terms and conditions specified in this COC, the General Permit
or the CAWMP may result in the revocation of this COC, or penalties in accordance with NCGS 143-
215.6A through 143-215.6C including civil penalties, criminal penalties, and injunctive relief.
Upon notification by the Division of this COC's expiration, you shall apply for its renewal. This request
shall be made within 30 days of notification by the Division.
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% post -consumer paper

Certificate of Coverage AWSO40009
Huntley -Vernon Farms Inc
Page 2
This COC is not automatically transferable. A name/ownership change application must be submitted to
the DWQ prior to a name change or change in ownership.
If any parts, requirements, or limitations contained in this COC are unacceptable, you have the right to
apply for an individual non -discharge permit by contacting the engineer listed below for information on
this process. Unless such a request is made within 30 days, this COC shall be final and binding.
The subject farm is located in the Fayetteville Regional Office. The Regional Office Water Quality Staff
may be reached at [phone]. If you need additional information concerning this COC or the
General Permit, please contact Stephanie Milani at [phone] ext. 544.
Sincerely,
cc: (Certificate of Coverage only for all cc's)
Anson County Health Department
axetteville;Regional�;Ofc�; W`ter�Quality&eeti»
Anson County Soil and Water Conservation District
Permit File
NDPU Files
D

State of North Carolina
Department of Environment and Natural Resou
Division of Water Quality
Non -Discharge Permit Application Form
(THIS FORM MAY BE PHOTOCOPIED FOR USE AS AN ORIGINAL)
General Permit - Existing Animal Waste 4peratiov_ tg, '
The following questions have been completed utilizing information on rile with the'lDi�sion. Please
review the information for completeness and make any corrections that are appropriate. If a
question has not been completed by the Division, please complete as best as possible. Do not leave
any question unanswered.
1.1 Facility Name: Huntely-Vernon Farms Inc
1.2 Print Land Owner's name: Huntlev-Vernon Farms Inc
1.3 Mailing address: 112 Williamsburg Lane
City, State: Wadesboro NC Zip:
Telephone Number (include area code): 272-7890
1.4 County where facility is located: Anson
1.5 Facility Location (Directions from nearest major highway. Please include SR numbers for state roads_ Please include a copy
of a county road map with the location of the farm identified): From Morven take hwv 145 to first rd to right turn left at
fork in road and farm is on right.
1.6 Print Farm Manager's name (if different from Land Owner):
1.7 Lessee's / Integrator's name (if applicable; please circle which type is listed): Carroll's Foods. Inc.
1.8 Date Facility Originally Began Operation: 1/1 1/1995
1.9 Date(s) of Facility Expansion(s) (if applicable):
2. OPERATION INFORMATION:
2.1 Facility No.: 04 (county number); 9 (facility number).
2.2 Operation Description: Swine operation
Wean to Feeder
3552- Certified Design Capacity
Is the above information correct? � yes; 0 no_ If no, correct below using the design capacity of the facility
The "No. of Animals" should be the maximum number for which the waste management structures were designed.
Type of Swine No. of Animals Type of Poultry No. of Animals Tvpg of Cattle No_ of Animals
0 Wean to Feeder 0 Layer 0 Dairy.
0 Feeder to Finish 0 Non -Laver 0 Beef
0 Farrow to Wean (# sow) 0 Turkey
0 Farrow to Feeder (# sow)
0 Farrow to Finish (# sow)
Other Type of Livestock on the farm: No. of Animals.
FORM: AWO-G-E 7/7/99 Page 1 of 4 04 - 9

2.3 Acreage cleared and available for application (excluding all required buffers and areas not covered by the application
Zr
system): I2.00 Required Acreage (as listed in the AWMP): 7.7
2.4 Number of lagoons/ storage ponds (circle which is applicable): I
2.5 Are subsurface drains present within 100' of any of the application fields? YES or NO (please circle one)
2.6 Are subsurface drains present in the vicinity or under the lagoon(s)? YES or NO (please circle one)
2.7 Does this facility meet all applicable siting requirements? (Swine Farm Siting Act, NRCS Standards, etc.) (Swine Only)
YES or NO (please circle one)
What was the date that this facility's swine houses and lagoon were sited? '718I9k
What was the date that this facility's land application areas were sited?
3. REQUIRED ITEMS CHECKLIST
Please indicate that you have included the following required items by signing your initials in the space provided next to eaf-+
item.
3.1 One completed and signed original and one copy of the application for General Permit - Animal
Waste Operations;
3.2 Two copies of a general location map indicating the location of the animal waste facilities and
field locations where animal waste is land applied;
3.3 Two copies of the entire Certified Animal Waste Management Plan (CAWMP). If the facility
does not have a CAWMP, it must be completed prior to submittal of a general permit application
for animal waste operations_
The CAWMP must include the following components. Some of these components may not
have been required at the time the facility was certified but should be added to the
CAWMP for permitting purposes:
3.3.1 The Waste Utilization Plan (WUP) must include the amount of Plant Available
Nitrogen (PAN) produced and utilized by the facility_
3.3.2 The method by which waste is applied to the disposal fields (e.g. irrigation,
injection, etc.)
3.3.3 A map of every field used for land application.
3.3.4 The soil series present on every land application field.
3.3.5 The crops grown on every land application field.
3.3.6 The Realistic Yield Expectation (RYE) for every crop shown in the WUP.
3.3.7 The PAN applied to every land application field.
3.3.8 The waste application windows for every crop utilized in the WUP.
3.3.9 The required NRCS Standard specifications.
3.3.10 A site schematic.
3.3.1 1 Emergency Action Plan.
3.3.12 Insect Control Checklist with chosen best management practices noted.
3.3.13 Odor Control Checklist with chosen best management practices noted.
3.3.14 Mortality Control Checklist with the selected method noted.
3.3.15 Lagoon/storage pond capacity documentation (design, calculations, etc.). Please be
sure to include any site evaluations, wetland determinations, or hazard classifications
that may be applicable to your facility.
3.3.16 Operation and Maintenance Plan.
If your CAWMP includes any components not shown on this list, please include the
additional components with your submittal.
FORM: AWO-G-E 7/7/99 Page 2 of 4 04 - 9

Facility Number: 04 - 9
Facility Name: Huntely-Vernon Farms Inc
4. APPLICANT'S CERTIFICATION:
I, — u� ���Y- i�c`/I�v.-� /t5;n.ru _Z c _ _ (Land Owner's name listed in question 1.2), attest IUat
this application for _7 aW74=V— a�2 -- (Facility name listed in question LI)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of this
application are not completed t if all rluired supporting information and attachments are not included, this application package
will be returned to me as inco ole . . /
Signature
Date
5. MANAGER'S CERTIFICATION: (complete only if different from the Land Owner)
I, (Manager's name listed in question 1.6), attest that this
application for (Facility name listed in question 1.1)
has been reviewed by me and is accurate and complete to the best of my knowledge. I understand that if all required parts of,this
application are not completed and that if all required supporting information and attachments are not included, this application package
will be returned as incomplete.
Signature
Date
THE COMPLETED APPLICATION PACKAGE, INCLUDING ALL SUPPORTING INFORMATION AND MATERIALS,
SHOULD BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DIVISION OF WATER QUALITY
WATER QUALITY SECTION
NON -DISCHARGE PERMITTING UNIT
1617 MAIL SERVICE CENTER
RALEIGH, NORTH CAROLINA 27699-1617
TELEPHONE NUMBER: [phone]
FAX N"UNIBER: [phone]
x
FORM: AWO-G-E 7/7/99 Page 3 of 4 04 - 9

BROWN CREED Soil Witer 4donserva11on District USDA Natural Resources Conservation Service
%M'A eT= i rni 17AT1nAl 01 A Al
Animal waste must be land applied at a specified rate to prevent pollution of surface water and/or groundwater.
Plant nutrients in animal waste should be used to reduce*amounts of commercial fertilizer required for crops (in
the Melds where the waste is applied). This waste utilization plan uses nitrogen as the limiting nutrient. Waste
should be analyzed before each application cycle. Annual soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize fertilizer value of
animal waste; and, to ensure that it is applied in an environmentally safe manner.
1). Always apply waste based on crop needs and nutrient content of the waste. Do not apply more nitrogen.
than the crop can utilize.
2). Soil types are important... they have different infiltration rates, leaching potentials, cation exchange
capacities, and available water holding capacities.
3). Normally waste shall not be applied to land erodingat greater than 5 tons per acre per year. With special
precautions, waste may be applied to land eroding at up to 10 tons per acre per year.
4). Do not apply waste on saturated soils, when it is raining, or when the soil surface is frozen. Any of
these conditions may result in runoff to surface waters which is not allowed under NCDWQ regulations.
5). Wind conditions should also be considered to avoid drift and downwind odor problems.
6). To maximize the value of nutrients for crop production and reduce the potential for pollution, waste should
be applied to a growing crop, to bare ground not more than 30 days prior to planting, or, to a forage within
30 days of breaking dormancy. Injecting waste or disking will conserve nutrients and reduce odor
problems.
This plan is based on the waste application method shown. Nutrient levels for different application methods are
not the same; therefore, changing application methods in the future will require a change or revision of this plan.
Estimated acres needed to apply the animal waste are based on typical nutrient content for this type of opera-
tion. Actual acreage requirements should be based on the waste analysis report from your waste management
facility. In some cases a plant analysis may be beneficial- and, allow additional waste to be applied. The land
area receiving waste should be flexible enough to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for the crop being managed and grown.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC 2H.0217
adopted by the Environmental Management Commission.
Page 1 ANSON COUNTY WC

.Ian ee ZI-1
BROWN CREEK Soil Water Conservation t> trict USDA Naturai Resources Conseffatian Setsiee
WASTE UTILIZATION PLAN.
Estimated Annual Waste Nutrient Production
_ tiasid on, metres bebvr
a
WASTE
APPLY DESIGN SIZE ANNUAL WASTE
ANIMAL PROD. UNIT TYPE WASTE SYSTEM NIMOD 0 CAPACITY PRODUCED
PLANT AVAILABLE .
NITROGEN (PAN)
Waste Generation Figures from NRC6 lagoon Deslgn, PAN Estimates from 711N6 NCDA Waste Analysis
Amount of Waste Produced per Year* 21.3 acre -inch approx_.5787136 gallons
Amount of PAN Produced per Year 1620 lb.'Plant Available Nitrogen
*Amount of waste produced per year does not include excess wash water or run6o 9 if any..►.
Applying all this waste in a timely manner is a big Lob ... re u6 n tim%planniag and appropriate u1 ment
The following landifield acreage in Table i and Table 2 will be needed for waste application based on crop grown
and waste application rnethod listed. See Appendix f for a list of Soil Types, Realistic Yield Expectations, N
Application rates, and Commercial N use assumptions used to develop this plan. See rewrdkeeping FORMS
(attached) for required waste utilization records that need to be maintained.
Acres Owned by Producer
LB. N Total
Tract Field Crop Solis Acres lAe." H I Utilized scre4rich Apply Mor4h
3000
1A
Bermuda
2468
1.0
190
190.0
2.5
May-Aug31
3000
18
Bermuda
246E
1.0
190
190.0
2.5
May-Aug31 _
3000
2
Bermuda
5T58
5.7
250
1425.0
18.8
May -Sept
3000
—1A
R egrass
2405
1-0
100
100.0
1.3
see Hate-App1
3000
--iB
Ryegrass
1246B
1.0
100 1
100.0
1 1.3
See Note~
3004
--2
R egrass
5758
1 5.7
50
285.0
3.8
Sept -Apr
' i nis N is rrom anima, waste only. I AL I _ _7.7 acs L _ 2290 1b. J
Indicates that this field is being overseeded {i_e_ rnterptanted), or, that winter annuals followsumirrer annuals
if nutrients from other sources such as commercial fertilizer are applied, they are accounted for in Appendix 1.
CAUTION: P and K may be over applied while meeting N requirements. In the future, regulations
North Carolina to have a nutrient management pion bW addresses all ntMents (H. P R it). This plan only addrossm Nitrogen.
Acres with Agreement or Long Term Lease
Tablet ::, (�greernent.wittr adjacent landownt?c'mlast;be coached)
(Ret;uired only: gydo if rator est not own adequate Wd: [see Required SPecificattoq ZJ)
LS. N Total
Tract Field Crop soils Acres IAc.• N I Utilized acre4nch Apply Month
No rented land for waste utilization
"See footnotes for Table 1. ITOTAL I acs lb.
Ammeaded I&M
by REN {NFZC:S) page 2 ANSON COUNTY NC

• s
BROWN CREEIGSoil Water Conscrvation District
USDA Natural Resources Conservation Service
WASTE UTILIZATION PLAN
Totals from Table 9 & Table 2
Acres Lb.. N Utilized
Table 1 7.7 acs 2210 lb.
Table 2 1 acs I lb.
TOTAL 1 7.7 acs 1 2210 lb.
Amount of N Produced
***<Deficit> of PAN
1620 lb.
-590 lb.
"'Must be 0 (zero) or <Deficit> in order to utilize all the animal waste N produced!
Table 1 & 2 Notes: - Acres shown are considered to be useable acres... excluding required buffers, filter strips, odd areas,
and perimeter areas where waste cannot be applied or equipment limitations may preclude full application
rates. Actual field acreage may, and likely will be, more than acres shown in the tables.
- See the attached map(s) showing fields referenced in these tables.
- The producer and waste applicator are responsible for ensuring that spreader (or irrigation) equipment
is calibrated, operated properly, and applies the correct rates to the acres shown in the tables. Failure
to apply recommended rates and amounts of nitrogen shown in the tables may invalidate this plan.
Important information for Application of Liquid Animal Waste
Refer to Waste Storage Facility Designr'As Built" Drawings or OEM Plan for amount of
temporary storage time, start pumping elevation & stop pumping elevation.
Irrigation/application rates should not exceed the intake rate for the soil at the time of irrigation ... or runoff and ponding can occur.
The inigation/application rate is controlled by initial soil moisture content, soil structure, soil texture, irrigation water droplet size,
and organic solids. The application amount should not exceed the available water holding capacity of the soil at the time of
irrigation nor should the plant available nitrogen (PAN) applied exceed the nitrogen needs of the crop.
The producer and irrigation designer is responsible for ensuring that an irrigation system is installed to properly irrigate animal
waste on the acres shown in Tables 1 & 2. Failure to apply recommended rates and amounts of nitrogen shown in the tables
may invalidate this plan. Application of liquid waste by other methods (honey -wagon, etc.) is the responsibility of the producer.
Ihe folipjffing_information _is provided (by -soil type and crop) to plan and evaluate liquid waste applica i n
sc edyles. These figures represent optimum irrigation or application rateslfrequgncies to meet crop water
needs and prevent water runoff.
Min. Irreg..
Frequency
Soil Type Crop Days
575B Permanent Grass 4
246E I Permanent Grass 4
Apply Rate '• Apply Amount
0.5 in./hour 0.5 inches
0.4 in/hour 0.5 inches
From NRCS Tech. Guide, Section 11- ENG - Irrigation Interpretations
* This is the minimum rest period in days between irrigation on the same land area under optimum conditions.
This is the maximum application amount allowed for the soil assuming nitrogen amounts for the
crop are not over applied. In many cases, the application amount shown cannot be applied due to
the nitrogen limitation. This maximum apply amount can be applied under optimum soil conditions.
Ammended 3/24/98
by REH (NRCS) Page 3 ANSON COUNTY NC

BROWN.CREEKSoil Water Conservation District
USDA Natural Resources Conservation Service
WASTE UTILIZATION PLAN
Sludge:
This waste utilization plan must contain provisions for periodic land application of sludge at agronomic
rates. Sludge will be nutrient rich and require precautionary measures to prevent over application
Broadcast Soil incorporated
Estimated Annual PAN from Sludge: 270 lbs. N 320 lbs. N
5yr Sludge Accumulation: 1350 lbs. N 1598 lbs. N
Based on a 5 year sludge removal schedule, estimated land area required for sludge disposal is:
7.5 acres of Bras, based on an application rate of 180 lbs. N per acre
20.0 acres of corn/sovbeans based on an aoolication rate of 80 lbs. N oer acre
All the above figures are only estimates. Actual PAN and land area needed could vary 25% or more depending
on sludge nutrient analysis. soil types. crop. realistic yield, and application method. Likewise. sludge
disposal on a schedule other than every 5 years would drastically alter these estimates
Contact your technical specialist at the BROWN CREEK Soil & Water Conservation District - Natural
Resources Conservation Service (formerly the Soil Conservation service) Office in Wadesboro, (704)
694-2710, when you receive a waste analysis report. Request assistance calculating
allowable application rates and amounts prior to applying waste.
Figures provided are estimates of waste production... excess wash water or run-off (if any) may increase waste volume.
Operation constructed to NRCS design and specs, and certified (0.200) 1/95. Acreage estimates and
irrigation parameters provided for underground maiNhydrant irrigation system design.
Field acres in this plan are based on effective irrigated area from irrigation design. Some woodland being irrigated
outside effective area (60% radius) for some gun sets. Additionally, some small amount of nutrients applied and
not accounted for outside effective irrigated area.
Note: Presently waste irrigation equipment is rented/contracted on "as needed" basis_
Ammended 3124198
by REH (NRCS) Page 4 ANSON COUNTY NC

r
BROWN CREEK Soil Water Cons Lion District A Natural Neso=ea Comsat "Dift Serdre
WASTE UTILIZATION PLAN
I . Animal waste shall not reach surface waters of the state by runoff, drift, manmade conveyances, direct applica-
tion or direct discharge during operation or land application. Any discharge of waste which reaches surface water
is prohibited.
2. There must be documentation in the design folder that the producer either owns or has an agreement for use
of adequate land to properly apply the waste. If the producer does not own adequate land to properly dispose
of waste, he/she shall provide a copy of a written agreement with a landowner who is within reasonable proximity,
allowing use of their land for waste application. The owner of the animal facility is responsible for securing an
updated Waste Utilization Plan when there is a change in the operation.... such as increased animal numbers,
method of waste application, or change in available land for waste utilization.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for realistic crop yields based on soil
type, available moisture, historical data, climate conditions, and level of management, unless there are regulations
that restrict the rate of application of other nutrients.
4. Animal waste may be applied to land eroding less than 5 tons per acre per year. Waste may be applied to land
eroding at 5 or more tons, but less than 10 tons per acre per year providing grass filter strips are installed where
runoff leaves the field. [See FOTG Standard 393 - Filter Strips].
5. Odors can be reduced by injecting waste or disking after waste application. Waste should not be applied
when the wind is blowing.
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated on conventionally
tilled cropland. When applied to conservation tilled crops or grassland, the waste may be broadcast provided the
application does not occur during a season prone to flooding. (See "Weather & Climate in North Carolina" in
NRCS Field Office Technical Reference File - ENVIRONMENT for guidance).
Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff does not occur offsite
or to surface waters and in a method which does not cause drift from the site during application_ No ponding
should occur ... to control odor and flies.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the surface is frozen.
9. Animal waste shall be applied on actively growing crops in such a manner that the crop is not covered with waste
to a depth that would inhibit growth. The potential for salt damage from animal waste should also be considered.
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be held to a minimum and a suitable winter cover
crop planted to take up released nutrients. Waste shall not be applied to crops more than 30 days prior to
planting, or to forages more than 30 days prior to breaking dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following: Waste application
cannot occur within 50 feet from a residential property boundary; a perennial stream, river, canal or irrigation ditch.
For other animal operations or swine facilities sited before October 1, 1995 - waste application cannot occur within
25 feet of perennial waters [See FOTG Standard 393 - Filter Strips]. NOTE. Local ordinances may preempt this.
Page 5 ANSON COUNTY NC

r
BROWN CREEK Soil Water Cons tion District A Natural Resoumes Comervadon Service
WASTE UTILIZATION PLAN
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those owned by the landowner.
14. Waste shall be applied in a manner not to reach other property and public right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways or wetlands by a discharge or by over -
spraying. Animal waste may be applied to prior converted wetlands provided they have been approved as a land
land application site by a "technical specialist". Animal waste should not be applied on grassed waterways that
discharge directly into water courses, and only then at agronomic rates provided the application causes no run-
off or drift from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall not be discharged into
the animal waste management system.
17. A protective cover of appropriate vegetation will be established on all disturbed areas (lagoon embankments,
berms, pipe runs, etc.). Areas shall be fenced, as necessary to protect the vegetation. Vegetation such as
trees, shrubs, and other woody species, etc. are limited to areas where considered appropriate. Lagoon areas
should be kept mowed and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge.
18. If animal production at the facility is to be suspended or terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate the possibility of an illegal discharge, pollution and erosion.
19. Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular basis to prevent break-
downs, leaks, and spills. A regular maintenance checklist should be kept on site.
20. Animal waste can be used in a rotation that includes vegetables and other crops for direct human consumption.
However, if animal waste is used on crops for human consumption it should only be applied preplant with no further
applications of animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and bottom elevations of the temporary storage (pumping
volume) of all animal waste lagoons. Pumping shall be managed to maintain liquid levels between the markers. A
marker will be required to mark the maximum storage volume for waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least annually at crop sites where
waste is applied. Nitrogen shall be the plant food element that determines application rates. Soil zinc and copper
levels shall be monitored and alternative crop sites used when these elements approach excessive levels. pH shall
be adjusted and maintained for optimum crop production. Soil and waste analysis records shall be maintained for
5 years. Poultry dry waste application records shall be kept for three (3) years. Waste application records for all
other waste shall be kept for five (5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina regulations.
Page 6 ANSON COUNTY NC

BROWN CREEK Soil and Water Conservation District Appendix 1 USDA Natural Resources Conservation Service
' Soil Map
Unit
Symbols
• Roallstic
Yield Recommended
Yield
Estimate N€trogen application per
* CROP [RYE) Unit yield unit
Nitrogen
application
rate planned
Commercial
Nitrogen Used
Nitrogen
Supplied by
Animal
Waste
Nam
SIM
575E
Coastal Bermuda (hay) 6 TONS 225 300
250
0
250
2468
Coastal Bermuda (hay) 3.8 TONS 143 190
190
0
190
575E
Ryegrass Overseeded 50 50
50
0
50
2468
Ryegrass Overseeded 75 100
100
0
100
Ryegrass to be drilled into short (-c3") bermuda sod by October 15
Waste application Requirements for 1000J PAN Application
- last application to bermuda by August 31
- 50# N may be applied tolfor ryegrass Sept 15 - Oct 30
- 50# N may be applied to ryegrass Feb - Mar
- ryegrass shoud be harvested by Apr 7...eny N applied to ryegrass
Apr -May must be subtracted from PAN for bermuda
NOTES: Tech guide coastal yield for 575B is G tons, apply rate based on 5 tons unless yield proven
Tech guide fescue yield for 246E is 3.8 tons, Bermuda yield considered equivalent
Soil -Crop Yield Data from NRCS Field Office Technical Guide - Section 11 (unless shown othi
'Recommended N rates from NRCS Field Office Technical Guide - Section 1V, 390 Nutrient Management
Rmmended 11M99
by REH (NRCS)
WASTE UTILIZATION PLAN "SON COUNTY NC

jan c �a uc: acP uaLri
SitOWN CREEK Soil Water Conservation District_ USDA Natural Resources Conservation SeaAae
WASTE UTILIZATION PLAN.
Waste Utilization Plan Agreement
Name of Operation:
Huntley -Vernon Farms Inc Swine Farm
Facility Owner
Date:
Huntley Vernon Farms Inc
Facility Manager
(if diMerent from owner)
Person Preparing Plan
Amweirded 1 9
by REH (NRCS)
Date:
Date: r
Robert E. Jr.
Affiliation: USDA -Natural Resources Cortservation Servioe
1705 Momen Road
Wadeabom, NC 28170-3142
Page 7
"SON COUNTY NC

BROWN CREEK Soil and Water Conservation District
Appendix 1 USDA Natural Resources Conservation Service
Realistic
Nitrogen
" Soil Map
Yield
"" Recommended
Nitrogen
Supplied by
Unit
*
CROP
Estimate Yield
Nitrogen application per
application
Commercial
Animal
Symbols
(RYE) Unit
yield unit
rate planned
Nitrogen Used
Waste
575E
COASTAL BERMUDA (RYEGRASS)
6 TONS
225 300
200
0
200
246E
COASTAL BERMUDA (RYEGRASS)
5.5 TONS
206 27
2200
0
200
NOTES: 200 lb N application rate chosen to be reasonable and not have unreasonable harvest efficiency
Application rate includes overseeded ryegrass winter grazing. Higher rates may be used if hay is harvested.
" Soil -Crop Yield Data from NRCS Field Office Technical Guide - Section II (unless shown otherwise)
Recommended N rates from NRCS Field Office Technical Guide - Section 1V, 390 Nutrient Management
WASTE UTILIZATION PLAN ANSW COWTY NC

BRdvVN CREEK Sod Water Conservation District USDA Natural Resources Consermdon Service
Hnndey-Vernon Farms Inc Swine Farm - OPERATION AND MAINTENANCE PLAN UPDATE
This structure is designed to operate as an anerobic lagoon, with waste treatment and 180 days of temporary
storage. Time required for the fluid level to fill from STOP pump elevation to START pump elevation may vary
due to site conditions, weather, flushing operations, and the amount of fresh water added to the system.
The 180 day temporary storage in this structure consists of. 1.) waste generated by confined animals; and,
2.) excess rainfall after evaporation (5" for Anson County). Additionally the structure can store the 25 year
24 hour storm (6.3" for Anson County) above the START pump elevation. The volume of waste generated by
3552 confined swine remains fairly constant throughout the year and from year to year. Excess
rainfall will vary from year to year. The 25 year rainfall is not considered in the annual pumping cycle...
this volume above the START pump elevation must be maintained and available.
The START pump or maximum normal operating fluid level is usually the outlet invert of pipe(s) from the
confinement building(s). If the outlet pipe(s) is not installed at the START pump elevation, a permanent
marker must be installed at this elevation. A STOP pump elevation must also be established to maintain
lagoon treatment depth and volume. Pumping can be started or stopped at any time between these two
elevations to land apply waste without runoff or leaching, and accommodate weather, soils, crop, equipment,
and management situations.
Land application is an accepted method of liquid waste disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation; honey wagon application is a more labor intensive/time
consuming method. Be careful when applying waste to prevent damage to crops.
IMPORTANT ITEMS
1. Fresh water should not be used for flushing... recycle from the anerobic lagoon.
2. The approved waste utilization plan shall be followed. This plan recommends sampling and testing of
waste prior to land application.
3. START pumping temporary storage when fluid level reaches elevation 98.2 (or before). STOP pumping
when fluid level reaches elevation 96.4. This temporary storage, less 25yr-24 hour storm (volume to pump)
is 38585 cubic feet (288616 gallons) every 180 days .... 77170 cubic feet (577232 gallons) per year.
4. Refer to the approved Waste Utilization Plan for important information on irrigating liquid waste —
application rates, maximum application amounts per irrigation and rest period between irrigation.
5. Keep vegetation on the embankment and areas adjacent to the lagoon mowed annually. Vegetation
should be fertilized to maintain a vigorous stand. Keep grazing livestock off all embankment areas.
6. Repair any eroded areas or areas damaged by rodents and establish in vegetation.
7. Keep all surface runoff diverted from the lagoon to stable outlets.
8. Keep a minimum 25 foot buffer area around waste utilization fields adjacent to perennial streams. Do
not apply waste in open ditches or water courses, within 100 feet of a well or within 200 feet of a residence
9. Maintain a copy of the approved Waste Management Plan on farm (or at the confined animal facility)
at all times. The Clean Water Act of 1977 prohibits the discharge of pollutants into waters of the United
States. The NC Department of Environment, Health, and Natural Resources- Division of Water Quality
is the responsible for enforcing this law.
11/25/97 p,NSON COUNTY, NC

Huntley -Vernon Farms Inc Swine Farm
Phone Numbers
Implement this plan if any part of the waste management system for this operation fails
or results in overapplication of waste, or discharge of waste to the waters of North Carolina!
DO NOT WAIT or PROCRASTINATE if there is a problem! Make every effort to ensure
that animal waste does not reach surface waters... or neighboring property!!!
This plan should be posted and accessible to all persons involved in the day-to-day
operation of this facility!I!
Post in a Prominent Place!!!
USDA -MRCS
BROWN CREEK SWCD
Anson County NC

at
Huntley -Vernon Farms Inc Swine Farm
1. Stop the release of wastes Depending on the situation, this may or may not be possible. Suggested
actions are listed below.
Lagoon Overflow
Add soil material to increase elevation of embankment
Pump waste to fields at an accceptable rate
Stop all flows into lagoon immediateey
Runoff of Field Applied Waste
Immediately stop waste application
Contain waste in a temporary diversion
Incorporate waste to prevent runoff
Leakage from Pipes, Pumps and Sprinklers
Call a pumping contractor
Make sure no surface water is entering lagoon
Evaluate and eliminate reason(s) for runoff
Evaluate application rate for fields where runoff ocarred
Stop recycle pump Close valves on leaking pipes to eliminate discharge
Stop irrigation pump Repair all leaks prior to restarting pumps
Leakage from Flush Systems, Houses, Solid Separators
Stop recycle pump
Stop irrigation pump
Stop all flows in house, flush systems, solid separators
Repair all leaks prior to restarting pumps
Make sure no siphon occures
Leakage from Base or Sidewall of Lagoon —often seepage as opposed to flowing leaks
Dig a small sump or ditch to safely catch seepage, install subersible pump, pump seepage back into structure
If seepage is cased by burrowing animals, trap and remove animals, compact day soil material in holes
Have a professional evaluate the condition as soon as possible
2. Assess the extent of problem and record obvious damages.
Did waste reach any surface waters? Could spilled waste mach surface waters?
Estimate volume of waste released and duration of event Could a rain event cause waste to reach surface waters?
Note Damage... employee injury, fish kills, property damage Are potable wells endangered (on or off property)?
Did spilled waste leave the property? Estimate how much waste reached surface waters
3. Contact appropriate agencies. See numbers posted on front of this plan.
Call the DWQ (Division of Water Quality)... Regional Office or After Hours Emergency number
Have the hollowing information ready.- Your name, facility, telephone number, details from Item 2 above,
exact location of facility, direction of movement of spill, weather/wind
conditions, corrective measures taken, seriousness of situation
Call local EMS phone number if spill leaves property or enters surface waters... instruct EMS to contact Health Department
Contact local SWCD-MRCS Office for adviceftechnical assistance (also may want to contact Extension Service Office)
4. If none of 3 above works
Call 911 or Sherrifs Department, explain situation and ask personnel to contact the proper agencies_
5. Contact the Contractor of your choice to begin repair of problem to minimize off -site damage.
Contractor Name:
Phone:
6. Contact the Techical Specialist who certified the structure (NRCS, Consulting Engineer, etc.).
Technical Specialist: Robert E. Horton Jr.
Work Phone: [phone] Q
7. Implement procedures as advised by DWQ and technical assistance agencies to rectify damage, repair
system and reassess the waste management plan to ensure no future release of waste. USDA-NRCS
BROWN CREEK SWCD
Anson County NC
Post in a Prominent Place!!!

Burial three feet beneath the surface of the ground within 24 hours after
knowledge of death. Burial must be at least 300 feet from any flowing
stream or public water body.
L1 Rendering at a rendering plant licensed under NC G.S. 106-168.7
Renderer of choice for this animal operation
Val eyFroteins-tnc.
0 Complete Incineration
Dead Poultry Only — placing in a disposal pit. Size and design of pit
approved by the NC Department of Agriculture.
Any method approved by the NC State Veterinarian which involves
possible salvage of part of a dead animal's value without endangering
human or animal health. (Written approval of the State Veterinarian
must be attached.

BROWN CREEK Sail Water Conservation District
USDA Natural Resources Conservation Service
Checklists for Anima! Operations
{2r �}..5
............. .. ... :...._ ....: ,::..:....,......:........:.,...................n:................. .. ::::r..:v:.:: r., :::::•::... �: ::. :.::. .� :. •.v.: :{.}.i.}. .::.5 .;•Y....r .. .]..:' :.Y. ''S ti :F.{.,( }.{:.Li �....: t.:.?,:..�.�.•...: :i.: ir. 3 }
.-.�-. :. ...... ... :. .....:.. ..... .. ...... � .. ..:..:....... .:....., .. ..... ..{.. 4. v. ..{.. ......: �.{..,. n. .. }..3�: ?.{.},::: �: • .v:::. r.'!}'rSi'e+:��l:i F�y��
. r.. r.. n j.:... :. Y:-�i...,, }. :#. ... .. .. ....::.:: :: ..: ...:.:....,.. 'ri)�i' r:ti):•'.�`:•:%��S:t•e S::' .ST..
y � {<.•:U:n4 :l'iS: ':i)fr::k::?{+.{{: r.:::;:a?::?i i:� :}..�`:{+?{t;•T:�::.: ::.L: r.:.�1'.v::':.:•:.. v.
". �+... /`�.^ y
,,, :, ;ii
.. :.:.: �:, :..��,g.yss � .; .!!�� .. ... +. }.i•. ... r..... r.....2�..,•r.^:.�:.::•.,•::.�::`:#CCi�o-»y:a?:•:.::a5{;itC�[�[;t't}xo::•.: :.:::a:•::.. :;;�:, .}x.:•.
r.}
....�..:........ .......... ..... ... .: ..... .. :. ... ...., .r... .... .:. .. r.... .......,.......:r.r...,..,:.......r...,,......,...:r..r.....::: •.�.......::.: •.::.:. ::.::•t.}:; :•:{t•r ;q:;.1{y:$:::'+; .:.. �:.}..:.. •: #.. .{.. n.#r.{:: .:.#.}..
-...:.:.:...:::-:s...}.....:....:.r�,�:.,�S.,:aw.,�r.:r.:t:.,a-,v.t�r:::.:.: w::.,�}.,.:.. .h•: xv:.� •• r.:�:r„•.,.r.r,.,-,.Y.{,v.•r..S:r:::..a.v.cr.v..k.}.#,:: r�CoSw:.��,�Lv:Lfk•$R.r££r'}.v.',:A:�:s+a'•4ir}:. ��i��xrr.,•r...3c$:'.. .� L o?�r..,�:•},...rr�::.,t.: ::�.
.... •„• v...... r. - rr:,rr.. vr.o:.:�- v: r.:. ..... r.,�::..:
Insect Control Checklist - Liquid Waste Systems
Source
BMRs to Control Insects
Flush Gutters
Accumulation of Soilids
Flush system is sufficiently designed, andl
operated as designed.
Remove bridging of accumulated solids at
discharge.
Lagoons and Pits
Crusted Solids
Maintain lagoon, holding pond, settling basin,
pits to minimize crusting (no more than 6-8
inches over 30% of surface).
Excessive Vegetative Growth
Decaying vegetation
Control Vegetation along perimeter banks of
lagoons and other structures to prevent
accumulation of ve etative matter.
Feeders
Feed Spillage
Design, operate and maintain feed systems
(e.g. bunkers and troughs) to minimize
accumulation of decaying wastage.
Clean up spillage'routinely (e.g., 7-10 day
interval during the summer, 15-30 day interval
during winter).
Feed Storage
Accumulation of feed
Reduce moisture accumulation within and
residues
around perimeter of feed storage areas by
insuring drainage away from site and/or
providing adequate containment (e.g., covered
bin for brewers grain and similar high moisture
grain products).
Inspect for and remove or break up
accumulated solids in filter strips around feed
storage as needed.
1jAWMWMI'G'
IN
ANSON CO LINTY. NC

BROWN CREEK Soil Water Conservation District
USDA Natural Resources Conservation Service
Odor Control Checklist - Swine
Source
BMPs to Control Insects
Farmstead
Swine Production
Vegetative or wooded buffers, Recommended
best management practices, Good judgement
and common sense
Animal Body Surfaces
Dirty manure -covered
animals
Dry floors
Floor Surfaces
Wet manure-coverd floors
Slotted floors
Waterers located over slotted floors
Feeders at high end of solid floors
Scrape manure buildup from floors
Under roof ventilation for drying
Manure Collection pits
Urine, partial microbial
decomposition
Frequent manure removal by flush, pit
recharge, or scrape
Ventilation exhaust fans
Volitile gases, Dust
Fan maintenance, efficient air movement
Indoor Surfaces
Dust
Washdown between groups of animals
Feed additives, Feeder Covers, Feed delivery
downspout extenders
Flush tanks
Agitation of recycled lagoon
liquid while tanks are filling
Flush tank covers; Extend fill lines to near
bottom of tanks with anti -siphon vents
Flush alleys
Agitation during wastewater
conveyence
Underfloor flush with underfloor ventiliation
Pit recharge points
Agitation of recycled lagoon
liquid while pits are filling
Extend recharge lines to near bottom of pits
with anti -siphon vents
Lift Stations
Agitation during sump tank
filling and drawdown
Sump tank covers
Outside drain collection or
junction boxes
Agitation during wastewater
conveyence
Box covers
End of drainpipes at lagoon
Agitation during wastewater
conveyence
Extend discharge point of pipes underneath
lagoon liquid level
Lagoon Surfaces
Volitile gas emissions,
Biological Mixing,
Agitation
Proper lagoon liquid capacity
Correct lagoon startup procedures
Minimum surface area- to -volume ratio
Minimum agitation when pumping
Mechanical aeration
Proven biological additives
ANSON COUNTY, NC

AN331AL leMSTB 11"AG M" PLAN CMATZFICATIOti FOR MM ,k EYpANDED FEEDLOTS
1120asft ratuzu--tha ccsapletbd form to tha Division of Environmental 2Sassagament
the address on tha rovarse aid& of this form. T ^_
name of farm (please print):
Address! i13y Ver nri-- r_. _(BWiE
. Phone No. 272-7890 2
k ter 28121 _ � County
Farm location: Latitude and Longitude._W 51j, 48-tv /_WD�a' 3T, (required)'is
please attach a copy of a county road map w}Swine th lolocationaon identified. d�`p�� •�0�.%
Type of operation (swine, layer, dal
Design capacity (number of animals)t3552
Average size of operation'(12 month population avg.)e_ '3r
ICP
Average acreage needed for land application of waste (acres)r 17
=-+e»aa�ry�s�ara�rs�asal�ss�ss ��fsaa�vra�:��:�aaaa�aswa��eas�s�sae:wasae�aa����a�awr
Technical Specialist C&rtifieation
As a technical specialist designated by the North Carolina Soil and Water
Conservation Commission pursuant to 15A NCAC 6F .0005, I certify that the new or
expanded animal waste management system as installed for the farm named above
has an animal waste management plan that meets the design, construction,
operation and maintenance standards and specifications of the Division of
Environmental Management and the USDA -Soil Conservation Service and/or the North
Carolina Soil and water Conservation Commission pursuant to 15A NCAC 2H.0217 and
IRA NCAC 6T' 0901-.e009. 'Cho following olements and theft cosrospendin tninin+um
criteria -have —been verified by me or other designated technical specialists and
are included in the plan as applicable: minimum separations (buffers); liners or
eq,iivalent for lagoons or waste storage ponds; waste storage capacity; adequate
quantity and amount of land for waste utilization (or use of third party) s access'
or ownership of proper waste application equipments schedule for timing of
applications; application rates; loading rates; and the control of th4 discharge
of pollutants from stormwater runoff events less severe than the 25-year, 24-hour
storm.
Hama of Technical Specialist (Please Print):
Affiliation:
Address (Agency),1J706 (bLVgl fEad, Wadgsb=, N—C MW Phone No.
Signatures Dates
�asva�a�as ss����a��rvya aa,r:ass��y �s�sf y.e�aa�vatyssaaav � a=��va=ays�:=
owner/llama gar Agraemant
I (we) understand the operation and maintenance procedures established in the
approved animal waste management plan for the farm named above and will implement
these procedures. I (we) know that any additional expansion to the existing
design capacity of the waste treatment and storage system or construction of new
facilities will require a new certification to be submitted to the Division of
Environmental Management before the new animals are stocked. I (we) also
understand that there must be no discharge of animal waste from this system to
surface waters of the state either through a main -made conveyance or through
r*-inoff from a storm event less severe than the 25-year, 24-hour storm. The
approved plan will be filed at the farm and at the office of the local Soil and
Water Conservation District.
Name of LA
Signature:
Nam* of Ha
Signature- Date:
dotes A change in land ownership requires notification or a new certification
(if the approved plan is changed) to be submitted to the Division of
Environmental Management within 60 days of a title transfer.
DEM USE ONLY:ACNEWO

Ain
ram._.,..
a1,
k
o
14
ILI,
S-i
CL
ou

neaosst residence (9,OE' than
1"'". fEel
C. UV"c *Iciilf OU-11,
s r-w s (farm',; tt, f imstil R I-tj 7
1 E-5.
S
Uarr;-w tr. feeder) X
lbs, =
0
1 t,5
is d I f j rti'h i i,q o?j I y)
5
weari) 4,- r 0 W o
f(E ad W:!;r, to feedEr) x
It,
1 U6560
1 bs
D?%rr ibE
43
1 bE
-- ___--- Qtal AvE;-A:IF Live
Weight =
1C165 W.
IL
U I RED V' t� I VoUIN RIE: IREAillPi (if LA 0-
V C. I J,.T� lbs. AN x fi-fatmort VcimeWF)
I b ALN
Ti s3ti(+rA Volumieff.1' Uit, - AN =
I Gil I k
ALL
19 1 IWF--;r4 CUWI fEet
ARAK VO-W,[ Fi!R K U*E- ACCM1141DON
vc,lump = "') Cubic feet
f. I A
1L"E"? U, V
I T.S i de t�:p I epith (feet}--._-------------.._-__--
225.4
Inside tqwidth j (f at)
116.0
TE-P c-f dike eleviti_,f, (ket) ------------------
v9,9
)_:,-ttm c-f la -pen ejevatirn (feet)--
F!-Pek.m-d (feet) -------------------------------
I
Side S 1 r.PES i i rlei d? I 19-nT, ) - - - - - - - - - - - - - - - - - -
2.8 1
Total des i gri veil me us i iiq pr i smcid-a I form, II a
SS!E*1 SSPENEN' SS/cSIDE'l SISISUIS2 LENG) 11
HIDTH DEPTH
z 215%5
1 j (). E, I fl. 0
AREA C;F TGIF
LENGTH # WIMH
Y.5 It, .5 42�0.7t- (AREA (f IuN
ARIA l-'T PUTTOM
LENUH i WIDTH
9129.7157 (.AF.,'EA tC RLIfTC111',
AREA CIF MIND - TICO
LENGM WHIM 4
(.AREA gF MIL,
* 4)
CIJ. P ILMEn" IUD' t (4xAREA MOSECTIO1,10 + ARCA L-1-ITIOMI f LIEPTII/6
4"L-- 5 4 . 6 27 4 A, . Q 31
IIAS eA-IcJ "
Total IIF5i-p-d Volume A,.,aj ia,',Ip W. FT.

PRARIA93F ARICA:
Lww,fo (top of dil,c)
Length * k, i d I- h
ZZ5.0 116l.rl square feet
Pui 14irigm 4Q,f afid lot vatEr)
(1-0 square feet Describe this area.
TOTAL DA Z61try7.iF 5qUafe feet
fiesijn tfiqorary stQta--3e psrkd to bt Ka.: lays.
V�-:ums of WRE,e Pre-duled
Fetes t. urine prAduction in 3al,!day Ter 1�5 1b, AN I . 74 7
Volume Jf!/.'Vfl It-, A01,11-35. lbs Ali4 1.?7 jall"day ISO days
Volume 1946-4,.A gals. cr 260ZI-1.7 cubic feet
110um.v of -434 water
It! i F i r ifif a.;,C-UT,t �, I fresh Wit? T User NV 'Va F4 I P-2 f I (,QrS 01- Vour!-,E
Of fresh water Used f.,r a flush System or excess water. Flush systems
that rnircuiat-e the lfagc-ctp water are ;cumitc-4 for in 5A.
Valume rr.il-3 a I I vri s/ d ay I BO d a f 5 S t o 13 9 e 11. 3 a I I o F, 5
per CF
volumSi cubic feet
-jt:.e rf rainfall in Excpss of evaporatica,
L
Use ps.-iod Pf timf when rainfall exceed; evaporation icy largest amount,
HRO day; O.".LE5L rainfall = 5.0 inches,
VO I UmE = 5.0, inches * DA / 12 ifi(11?5 Per foot
Vi, I sufle 7 10,475.o (Lit -it feet
1}. Vc-iump of 25 year - 14 h(Fur Storm
VOUME =
6.�� itichin / 12 ijichs; per fc-ct f DA
Vo 1 Uge =
1,-, 71)(L 5 c 1,11 ;. r feet
TOTAL REQUIRED TEMPARARY STORAK
1 ut. i E feet
c ui, i c ket
71 f. CUIL fE,
1-7 Cubit fp;t
KIIAL
5'_'.r:Of I Cubic fEei

s
—` -4
_ , Si Itt`iRfr'r
Te;Ipr,rary storage pe!"iad====______________ 1�.- day=
Rain(aII in excees of evaporation:=====_==___ 5.r1 iriches
25 year - 24 hour rainfall`-==-_=________= 6.31 inches
fleePi3rd____________________________ 1.0 feet
'aide---- --__- -------- - -- --- p i
Inside top len:att+===________________________: L5 -0 feet
Iris lsJe ttp 11m, feet
Top of like 'i°.'{ feet
Bottom of lagoa.ro eievatier,====-==-=--=--= ,-:a feet
Total required vrlulilG=====--____-__- 1FT18'! cu. ft.
Actual desl n v.lurn_ ----------______-___==?161 air.°3 cu. ft.
Sea.rnal hi if, waiertat'le elevation CU feet
St..p pulpin:t elev.__________________________. 96.4 feet
Nu5t to : or = ;o the SINT elev.====_-____; 0,0 feet
Must to r.r = tc mire. req. tleatmet+t el.=; 34,`f feet
1;e-tuir"cd ni0mum treatlnilt volume===—=_=-__; i06 6f, cu. ft.
Volume at stop pumpiri9 elevation=====_______` 10_75�, cu. ft.
Start p:umpiFag etev._ ___________ _______=_; .2 feet
Hu=t t,=_ at t�*tarr, of fre-t-oard 1; 25. yr. rainfall
Actual volume lets 25 yr - Z4 hr rainfall=== 14 f7R cu. it,
V*olume at start puFPpir!q elevation=====______; 1.45544 cu. ft.
Required votume tt, to pumped=====-=--=- =-- 'b`98 cu. It.
Actual v(-Iwf!e to ire
tiir+. thickness vf sniff liner when required==; I C. feet
DATE:
API" jDVED I Y:
DATi:.
1,t+TE: EF_E ATTA+-F1=D AASTE ►1T41EN.ATION 11MI
qrft
i
tLNtPIT5:_ttt,�_
---_-__ _---1----------------
of-O 8W
PPG,
ki
"A , �6a0

�,Nr-,Nv---mtNT BLDG,
F jgj.5ot b FI DoR r--igv,
6
ckoss VIE\U D P 4� DNF —A'�`rC-G LA&DON
P I-T R+Ec N'A RG �Es1Crc1
Q,T OM o ;: sutM�
L rr_vI' =NvE-kT o;:
s-tiR�aG� IEL�V,
Qa1,y+ 7o� of DIKE
. eL a Y,
• 1
11� IES %4
I f
Ll
1 10 VE lcl D F I)VI I
�d�•z3 E1cV,
�AC►OD � � D, O
oti-rr om S-L t . 9
w t4 4i2aA5 a ZAYY LlGT ARM. 0ATePZ14L.
�+lQt �tJGvvtiIT'G 'Y W G
-Tv la->14QVAT �I7 I� Nt rf.r - r'r' 1. I21-
.
/�ry La hr f�, C7 VY ► T �-1 G � Q f't'ldi�� l%
V L1T t► f- t al—

............. .... ........ .. . I . .....
som
622
17!

• - E
CARRO-LL'S FOODS, INC.
P. O. Drawer 856
WARSAW, NORTH CAROLINA 28398
2
o'�•pQG
FACILITY DESIGN AND
WASTE MANAGEMENT PLAN KF��
FARM f
NAME OR NUMBER
FARM DESCRIPTION
LOCATION
S (Z
k4e'7Y Vim,_ — — — - -
COMPANY FARM
h
CONTRACT GROWER 7
:':'ARVATIM DISTRICT
"1:?E r4ADON S FIRST°
1706 MORVEN ROM
WADES O, NC 28I70-3142
CAUTION' i � Q ��� + ��;� 2ii] i i°. NStardhg
} 3•
MQ
Check for Underground and Overhead U? �; ,r� �3'a� ���1RVE►3 FUr:a
i��1 41AMSBORO NC 2817C•' 142

TABLE OF CONTENTS
VicinityMap.............................................................. 1
ASCSField Map............................................................ 2
SoilsMap.................................................................. 3
Soil Investigation Worksheet ......................... 4
Waste Treatment Plan ....................................................... 5
Waste Utilization Plan ........................................................ 6
Operation and Maintenance Plan ............................................. 7
Construction Specifications for Lagoon ....................................... 8
Seeding Plan (Farm Site) .................................................... 9
Computer Drawing of Existing Ground ....................................... 10
Existing Elevations......................................................... 11
Lagoon Cross Section Diagram ............................................... 12
Computer Drawing of Proposed Lagoon & Building Pad ......................... 13
SiteBalance Report......................................................... 14
Computer Drawing -All Data -Proposed ....................................... 15
Computer Drawing - Contour Lines ............... 16
Computer Drawing -Sloping Lines ........................................... 17
Computer Drawing - Blow-up of Lagoon Corner ................... 18
Building Pad Elevations..................................................... 19
Computer Cross Section -Existing_ -Proposed -Balanced ......................... 20
Facility Overlaid on Existing Topo Map ............... ...................... 21

MORVEN WEST. QUADRANGLE
NORTH CAROLINA-SOUTH CAROLINA
1.j1,B . MINUTE SERIES (TOPOGRAPHIC)
000 FEET
C.1 ,
0

+�: ..i r - ,,jy�_. , r C''�Y � � v. f a'���y. 3L�+.s4• . w'.. - �.: -`•: � .you 'yam •' , r •� ''�'-*.L1'., .y-' w r ?+��.
• 1„ 9r w•i �`+,i7., r i L' � 1 *'.: +"M � 1'R1 �L°i Y 1 .1 T]T`..�Y rrt _ .,,�:{� + L
.`,�,±j :,.c; .S, :R , �4 .r ., ,i�d hn� ! ,.;I F r► ire �y "'`�,y lr 1 + ,/:. 4• �<1 , Y
•7 •�:.�'- Z ^x � ••� �' , i f, M.. a•, -i+ r Y� a..rH' 'r• 1 _ . ie y La3.r� r ,r,•'�+ � �i' „1 � r
�'�� L� �•"�r:.. i �'' r • " - �.r:;•••' ' �.; i �r•i. r ••�:�� _.-r. r .4 - , •++t„*e);� � .j �.�,� � r .r . W .w` d r.
-'••F ti _ s •.+- r r �•'' ::w�T: • S•'.'1:._ • .t _'ti'r'1' _ _ 'C• •+=_� r .*n; •Y r .:i w. va.G-•;rf q 7 t
,� :is � / _ t a` t !.y s• - ^- ' '•.M.I=wS � y,:,• rC.'' : � i-F'.` � . •_ r +L
.- .'•'' '~ ` ',�, r ti.•:. n`•t; y .ei ..'ten i.- ��.?��.'�=-~•-.ifr.w .¢�-^1. �. ' wt�.
,v-f;: _ Y • f� [..•ilw,'.�• '•a S, ,.i;r 7 a ,• .,. -^+-:i -f'' i�f'�:� T•� ,cf
- � a / t r ai:. �- .r' � .: s...•t *'%":'t:�w * t: .. `X.:..4.. +='�'�'.a.
.iL.;' �y��?�.,u•Y. .';, ,: �`��•'�•'��"I;.ii y, ti' �ry�J/'. ,�, w5 4 r�, /r �jrr / r��•,..1'r+ ��"r.'�•
.' .l .,�'��1. ,i'r: _ ie a.:�._ a� -� fit_:; ram, � '-a• iw�..
'o aM!• S '-*" e•`�_.. • ` �''_Y: `•A�',!�'�ar; ray �: '_wCE.'° w+ -_ ,� :: n:�, Y++� `i-`-,-r'�R �* :X1; •!� =. ��v.
��r I'�'� + �'�i,i�• a.. �.ti- i"�k�:� q r wr�•�._`•' L �_K••.=� � _�1� i`ti•..�` 3w �,�-'•:• i.: , �-.•.,, � �^_
�r•si--`�;i'-''-'•'%' a g:r'i7'�` •'ti i�i : ::.' .•,,•. '.t ,• w`.5`•.a .r .� y _ • �'.' . - :,:;. .t : it. ; :.� - • `_ __ •:,s •� .i
,�j� 'i.. .c•. -.l �; •' = t,:. c.taM!`.. •}, � _ .,!,•�� a� t.1•• �•-iN- r.,y�Kµ .� � S, ':/. a -'• • ..
T:""�t�a�'..f74'"� •t:;:��:[�f_��C� �r�.iw_ t•s., rtit• .r.��:�--���ti••.,'� �.s::;i,^;•C _wr,d - / F t+ •�;.Z �.'� �, !f' -; �_
:T}� _ r•?,+:1'• � ,u '_'� �-r�. i x j ~.i`� c - sy..." 'd' P _.. ., - :r
N`c`ql
ti. o :--+x .= ti '+g'y, + �.!Q,sk' Yj� v..1 i ; ; ? ' ~ Y�" 4�"'t,.: •: a `fit 1
:T�.•�+'�T -�'t, 'r-'•".-.mot'\:Yu .: -.• %,`4�- �•-'"�•�i-•:_, ''l �r .ry`. - �`••-•
o.. :'r ;, �.[ 1. �� .�,q]-.tip• -.4L� • v'4.0 ':.n' ::+• ' �'}^ yf, ��� �:;;��� 1 /.s �S�ti::•;::• '•� +; r; _
/ .S. '^ ` =yam \ t - h �i `t4 � a' yy''ts�a.. l.� :•f-• -�,F�� `r'�4; .' � ..,�"'(T. Ji-.v+[,_ �'=A� _ �(T�/ •t ,1' •. :,L + _ .�vrjr„'� �i-'�'.,
:. 7�, r µ� +t i♦ .It+t � trt i L -`a "S �Y' Y+.;.�..�•.•'�•.~ �• -Y'� r -��.',`��- �Jr: w\�,ti tr-
'� i'� _.s r - ; r t r1 . - .1 ? v . � Y � • . ��.:...yrS,•a '4•+.• .fy.'� :, :� R. - ry. -e. r 5.
rf'• •..'# i +� v 1;•y�.:=.r'.,j - a.. •I- •j?�,. .:.: `:+.� • ..L �:r.;. Yr"•+i' ii. x• ' w
17.4t+` ._� ;h'.. y'?i' :l, .•n �'` - •�••' r'.?r jlh` �: �:`: P�' ""•: �'�w.�!�;-•+r "�.w;wral ti
• �. '' T, t � +', rjL '�'��:t�q' �� '--r ., .. '.•+•'.r. s i:... E N, •� t+i. �•a,•...-- • ra• _ �
i' -T 1 :'I ti Y c j-tp
r
�• :"'.. �g" '::M1'i "�yr� r = �-+ �_ �,�F _ l st R•i.: .�� ��l+ $r 1'kr��= `�J WM/.• •.i:' i"•'-L�.r t �� T �� 'tea.
-S t _ r. si • 4a. /".' +'[:''•'• i;•r r^ ,r' .p`, _ t«r - './
9� s Y .• )-..a 12 •� :1 _ �:. :^ � . �. 5'.:'._ -0w. :t t f_;"•i• }:tt el ~:*^
•4. ,•l la,•R y t ir.r•.'- si o�M 'Y
=ti•: •' ?. ,.1 :Y.tiy r� :.f• -..
i` � •'li •a� •'"" 1. t . ','':� . ,`U -,-Y•? ,/.. Y. 3•,."%
+(i �� . i�T.�CL' r fit. iT. � � F-1 - ?'r' �-.., _ L� '' a. :•!. w 'a 'r .
� a t 4
` tirL;,.. +n -1'aQ� s +•••.: t ••`-r , r f 's:, .n` 1 1' .. .:.` r �. .a:� i •�'44.. y.,;L'1}ti.�.�?..t�• � .'':�.`:,•� fir +l`�'r-•Pi{ M a '�-r. f_r '•. ,{,,r:.,�„�i, F _ =t'•' t •!'
_ !4j,t.: ,11�?t:Wtl-; a 't�'l �',; . '.•'•!�•ti •' :�`,r'Sa ,'i�"�:�r'y��'1.7-. Y.r'� {:::.. .'a",%•€.C' _ �:.�s.:
a r;�•t � �,;, � �1: ^{t r�'�,;ti•r: �,�� � s �� '� ��-c •i•: y.�.�:..;�'� 3_, 1�"•- .�. �•: ��.,• ` ) �,'
•i6 i Ly7 ' li�f s`:;;1 't'7 -„•� � �� c ': _G} tii"!`c , Y -� 4 L �', `�a' � , r n' - f=r.�, , - �• �•;�'3 f-1_ •� a `li/ • ' �
�...- '� .�,� .L _'r`,- ,�•�'r% . �y,i'r! r •, ,�r� .a '?• 1• t - � ;?'•� � 9. • "'arw�!.`-, n �-•,- '- -
ti �.. a� .:fir' �.. .�y -./ � r/'--�. � :1_• -"!. '�ti}.�•:-. ^��.; . _ - ' e �`�%''; • i::'^�`i... _.t-':
Iswl 'tc -t'- 1-"i�•, • _ •yr'`�'1•i S: % ., bra,:: +i'rt'•,,. _ � n•. ""4J• • �,:s: r.. s4. • 7 ,
S.=+'�' �L'� +•'' ��i •-►�.•-S :r',,..... a.•y 3. �- '� - ur. .�'.,•,- r _
=r • w,��} "'yam ,� ty�� '- _2►'�• .,yj..�x ���'•^. i^,.;•_:_::, fr `^Zi .=w _ '+� ^�� � ` �� �s �,
ri]'•� .w .�• :,} -�` 'tir t.. y.;�,'r",pi� 7,, i••.� : F. .�,.�• _ .+. ��"i� r •,;r" ,!ti Ie, � a � !: - _ '.1w -, •-«Y�'` $.: - '� tlrr :i�-; `� �r :�i•.;.^v •''lad ,j< �! ea. _ t v .,.. ,,`;,r i•.. .,+..r' 4 , :a . l _
� i''?,
s z t� 1 •. „; . i ¢ r -i r , / a�� -
:1i-r ~✓ 'r'�R. si :•. K. _ .iS .,, �;a' .�^ic j' . �.. i•"[ ��� f� 3ch i/:"'l`' ` :s �• 7- _ '; � r:M1 !F i-' "v -i .� p :'�y/a ? �y _
i.=�'�i•' y". j_ �:+"tip :�?" �.-::
r '' w: S, f - �-�--.:.�.�". += ,.,�+•t �la••�yyt s, w.+:•: ��{•r,: _` yi � :y,• •• .t� r
..!'� �� yr� �r _,yy' _tZ�r�"'tr�y /� �, �c1t�.' �L, w,� '... 1r��' -�'_ t':` ►"'1��y t ,"r'��.."C�--�";,�L :�a�.�.+' �.n -1 � � '�7 _
`'+;.�74+. '; f. rw-�'Y-g �71: .� -•'�", 1 r•r j. aiT ti.'r t.�. r._ 4. '•`•,j ,{Y"• 'r vL..L
r+�i: _ 't .i '• .*.�: "� - •!y'," 'tit' �,:' F` � r• :: r _ �i=.+-ir' '3ti 'k -+9:•" ;•Y. L 1�• .:t
. I.�i":h -�+ii Lt�Y .r-S'::.�t- 'i .f� Imo+ -4�CT�bt t:� ����r •y:_.,ll.y=-. :'�7~..•,Y �'�::. �' a'�`�:. �i.,..::�� _ S�y _TC l_� � a." t:, -
1••:'�'axa+:;S` 4 '�`"-wi'� .i�:'�.' �r�' .i`,c Se •.: J yG'
:+ .i:t ice, ""�•��', :I ;'as. -ai.�Y a � �:�_ " _, :'—G7�- ^wl'' rff f�'. •i; �La- _ ''�"r r`•'' � �`,�?'r'+ws.- Y -�"a�� ��'y4�• ,�
oirt7. � ��•�. i=.~'`il " � .,ra.!r ii �I1- '; '� '. f' '' ^-'�i' � :3 -�S . .."l �•"•. �• _?• .. r: - ':f4-
4:�'�i�.yyr 'a'ir -if"?j.'�C:.': �. .:�'da:•' c �:' •a �:1 l : '-?��_.;�. �y�'Y'�. '^.' '��`
tr��:'''S ►:-61.•sa.�y_,��w,_Y,� �y�•.'�. ,M.,IK:.'� _;N. :yr• 'n`•..^,',.+.•.Jr� - iyT•s.�i�••i!'�:::.•.� .;n1•..,,,•,y-'�1�.,�,
'y� + aM• ,�. Liil�rorrl ;= �''�l' •.if'`L " r '= t?+ i•' :�i.:. w+•,ri�• "7, Yam'i] ...; fWflj t tiles` f•"+ y}� ram' �Jt
�•r�p•��i .i>-� :�kar�.r: �..'.T,. .�.a" a .:r i •ti cTr'`+.' r �`"•' - .:�`'�: �-i:a,t:..;, :�.�.:• Y`•w��- �i✓.! _ -� ����
�,pp., ��, 3 R ' r j�"'A ; ray ' • ..L.' 4,fw+.
.{{'• �`�,' c s,�,` tr;Y'+ :4 '•' - ' «x'•4. 1 rt .+. >' 'M ,-•r - �r ; y:j+. "�,.':a .,"'.y�� . ram. L.1. `' '•- r':
is«, } f•j =_�`:::.i? f_� *,«.. a• •/h :ate' i .l ' :lr!i r" ^ +4Iri-
:g7.w7�'
:�1'!- k � y�'_..L 1..7�io•a:::?. •:F'' �'�' .'j•��:;••�f �. 'i�.r_'r' :-�:ri-�:_:��''.: :tea. S. -.,4r r�;.:i�;. .mac �'�".,�+, � ��.,
1• '' L �..":' .=i�� y�r t -+._� '1•+.L / -R' 4.':: f. ;�,.J, rrrk �:;.�^1 'a' 'f_ i- 'a- ".�•Y'.-+
t ���. ✓ r',�. . Si .Ji` A 1. !. '�i �i` J•'• = ^�'µ�L. - �` '
'='ti 1K' : /'+ Y -'F•{a � ;! 4 �1r \, � Y'+I' ;= 1 3�r"a _ -?';•- .L__ _•.••.' - - �'i. '--'���- -� �- r.`1 � _ +� _ l
"'•'iF.'.~r'y7,h.y .0 �� _ `.'}.1 �.•,•-..e• �; ;y' �C`:i:,r ' '�rf Z� O,._'11..:�.ti-,,t^.• --�.
;.`� •:w •R^i �.y �• t`'•i.ti �. Xij i4-,:.:.;, �ti i} �, ° ' •� �:- _,.1,�::1..'•..1 �- �'
y.�: • +� ..�.
! � � � ,S; ' ,1• � a'^t,,. ` �: ''`�: ' �•'x- ti i;�:_ c r.", � i' ^ t - .r r[ �i -�;-.
.. +:' "r _ •. fl'I,={:.''.: �': .'t,��;�.,;,w� :�... ..�,�- 1� �� S. - ��.�a. .r :ti 'Tr J» f `•, y ✓� ] -,.,
.4»;,i; tM �7 „•]t^ .s.' .'`yt'''»Y. 'r.F�C►�:�, -1 1 •re' '•s:. 1 - at't'_'1 .r' S'
r sif� �1i {�:'+1�i�ra .'ti=,"'4tr •S-•,4 ,r; �.�,•,. �L •. �'ti''�r.'..'r= - - 't• •,..� �F•.y�. .'�
.-'` •• _,,.�' -;� - y,'-a `"i a �•�� .'S�aa,tr:• r..:•�- , +•��• _ : yi: 4_•...:-fit '• - _ :� '::�
..ti 'i'_ ..�;';1. � • -tr_. ,'J� -�,t.r., Ly .., ..Laa ':. ':•'t+ :.�: ,.f •• •4�•_ "1." - ' 1.
:�^ •2�' �'t. .?1...tIQ.,•ti--'+•L•j` 1• _ L {••.'•' 1' .•4 '�.-rr:r• �.:' .1..
•i• Y'�.Y.,. (' 'Tr `.iF.n �- _ ..i-ice' _ :•r ✓!'"~ '
" ,Z:S'=N `1 .'} ,�... x: .tom .a «s .:" -�l•' -' �• ..�.:, • - ahf i c L+y, *.'J+r-�+, �A:'� _
:?�,. •��.. 'nt- l ::�{. tt ,r•�•at_ /...•,• ;s-++G`•' 'r' _ t. .,,,fir,` A a.
, �.y' �y'r':�-. ,�•• :?}� .*.5r H� ..�y}I,{••;•,i"r, �- tr •i•..1 `�` -' a_,!•4.; ,'��,i� :r`ti `��..: � t., ' r�- s'� ;�.
% a�'i� t�'-'�-�.•��.. Z•'h`„ .4'�•.7► �'ijt ,.. '1 �L�,, `�}' �_'. •t'•i •' �.it` r4L.A,_- •s:'��A � t+° •�ti•.r ,1/.r ti �� LRr +rai4;y7,"
..r<' r "�tu'�•�``wy�'� r,SW_ �,..y �..�'T•._''•�',:y.-rl-;�..: .��'.F:,�`•..'f� r, :�. 'ti.i,•,•:,:• ..yri� -1_:';�•
"�-,� 't !� �� '"Si^ ''i �•. � ,CrP'' :i.:�•.1,� a --fit ..-� kti'' ,y.. Gt f ::
���"� ��� '+i'. -�N=«tr •fir .�.�i �.. I•'��:y..' /� - � � ��• ��•-`�''r-tlw -•� ir: �.•�.i..

MJ
N
0
0
IH
LL

S C, I L— S I hJl l/ IE S T I R a0. T 1 a:r hl
Eddie Huntley
Anson County NC
Investigation Date: March 25, 1994
Location/Description: ASCS Farm 2162 T-3000; south of and adjacent
to SR 19607 west of SR IiZ5
Method Used: BacT:onservationlst
pits
Conducted by: Others present:
Robert HortoEddie Huntley
SCS DistriEd Huntley
Lin Taylor, SPICD Tech.
Carl Hi I dr-eth._ backhoe
operator -
Mr. Huntley is planning to buy this property and build a Carroll's
Foods contract swine nursery (3520 wean--to-feeder operation).
Swine waste produced in the nursery will be held and treated in a
waste treatment lagoon prior to land application. This soils
Investigation is to determine site suitability for constructing the
proposed lagoon.
Site Summary
Sell Map Units: 5 5B - Ailey loamy sand, 246E - Badin channery silt loam
Findings — Seven test pits were excavated._.one.near the proposed
building pad area, six in and around the proposed waste treatment
lagoon area. Predominate soil materials encountered were SM, CC,
ML and some SC (see unified classification legend on back of Soil
Investigation Log Sheet). The CL, and SC materials have relatively
:Iow permeability when properly compacted and make satisfactory fill
mater('als to construct an embankment. Depths and thickness of
these CC, and SC soil construction materials vary (see Soil
Investigation Log Sheet). Weathered rock and root: that was
difficult to excavate was encountered in pits 2-7.
General Soil Mote: This site is near a contact area betyeen residual piedmont soils (from Carolina slakes)
and upper coastal plain soils. Coastal plain materials are on the higher elevations... pit L
Conclusions — This site has moderate limitations for construction
of a lagoon. Decomposed slate rock materials were found in all
test pits excavated in and around the proposed lagoon area (pits
7). Since the lagoon will be ex; avated below the eIevatIons
exposed In the test pits, the amount and density of rock that will
be encountered, and difficulty of excavation cannot be estimated,

Eddie Huntley cont'd
Possible design considerations due to these rock IImitations on
site include:
- shallower than normal lagoon depths and larger surface dimensions (length and width).
- variable lagoon depth - lower lagoon bottom elevations along bottom side (away from pad) and higher
lagoon bottom elevations at upper side (near pad).
- lagoon location for deeper tuts near pits 3 and 4—weathered rock exposed in these pits appears softer.
- using borrow material adjacent to site to raise pad elevations and impound a larger portion of the lagoon
area. (Note: borrow areas need prior approval of SCS/SKO Technician)
There are CL and SC" soil materials on site suitable for
constructing and lining a swine waste treatment lagoon.
Stockpiling and zone placement will be required to mam-imize use of
this suitable material. A i - 1.5 ft. compacted clay liner (C:L, SC
material) will be required where rock material is exposed during
excavation of lagoon bottom and cut side slopes. Some of the
overburden SM material and other unsuitable excavated. material may
possibly be used in the outer- shell of the embankment (see attached
zone fill detail). No consolidated rock material greater than 6
in. In diameter- may be used in the outer shell. A sheepsfoot
roller must by used to compact sail construction materials during
construction of this lagoon.

UUIL INV29TIOATION LUC SHOn'T

J
. 1
I*vrES Ur MATERIAL ENCUUNTERED IN BURINCS
(Use one of systems below)
UNICIED CLASSIMA,riuN
GW -Wei! 'tarled praveic; gravel, sand mix
(W- Poorly graded gtaveis
(M-Sllly ptavek; gtnvel-sand-slit mix
UC-Clayey gtavels; t;taVO-gaud-clap mix
SW- well graded nand-; sand -gravel mix
SP - Poorly gtoded Bands + E
SM - Silly sand
SC -Clayey sands; gnitd-c1gy mixtures
ML - Silts; *Illy, b, fino dandsl sandy at clayey slit
CL-Clays of lode tb medlar plasticity ' :.j
CI1- lnotgonle days -of high plasticity'
MII - lal11stle alit"
OL-Ototanic foliltt and *illy clays, low plasticity
Of -Ofganle clayat lrtedluin to high plasticity ' '
USDA CL-ASSIFICATION
V gtnvel
s - Band
vfs - very fine sand
hi -sandy loam
fal - f Ine Bandy loom ,
g1= gtnvelly loam
el - gilt
all -silt loam .
d -cloy' loath
iticl -silly cl*y lost"
foci - gnndy clay loses
Bic -silty Clay
r-elrtq
1. Einit*bl* triaikHal (or etnbeakm6at It ivelltibia O Ye8 �� No ' {r„dfcer! mar.• IvaeMa air rA. s4rkh a►r
nwr" fld+l
` ' �lct ,rt�d r' .�0�¢ �ro � t"'►C��ri Gi � 11Ct`� '�C Cd �d
Z Etrdlllltt 6afattd• tfrttiltltatt bp6cie.i ktteriklott in dp6lgtl . f5e.veel, rp►fn�..rvdl �r�j" .
7-.1
*40,
6NOTgSN0TS5
6"to
lie,i7QTL5
NOTi3S
-0I
'
r
-
T
Ak % h
C

• • SM-WFO 10/93
TOPOGRAPHIC SURVEY INSTRUCTIONS
Landowner-/C'.ontr-act Grower-: EDDIE HUNTLEY
C/O ED HUNTLEY RT i BOX 79
MORVEN NC 28119
Proposed f ac i I i ty: Carroll 's Foods Contract .Swine Nurser
Field Survey
- Survey 50' X 50' grid with random shots as needed to identify field edges, special featuresi significant
topography changes between grid stations, etc. - -•
- Establish TBM (usually nail in tree, corner of concrete pad, etc.) that will not be disturbed by proposed
construction. Use assumed elevation of 50.0 or 100.0 as appropriate for TBI.
- Include following special features in survey:
Soils investigation pits (usually flagged and numbered)
wells
Above ground utilities and known or marked below ground utilities.
Residences (other than landowner) if within 750 ; 1000 feet of survey area ... only the closest corner
or side of a residence needs to be located. Note: if a residence is found within 750 feet of
proposed project area, contact the landowner immediately!
Finished rOPV Map
- Scale - 1' = 100,
Contour interval - 2 feet, labeled every b feet
-.TBN location, description and assumed elevation on map
Elevations printed for each 100' grid point
Soils investigation pits located and labeled with name and elevation
' Special features (wells, houses, utilities, etc.) located and labeled (elevation generally not needed)
- Reference hub or other landmarks needed for layout.
Special.Sife Specific Instructions
See soils investigation for Pit numbers
Sketch of., Area -- including topo survey area dimensions
Ver- € fy with Gar-ra l I ' s representative
May want to survey larger area than normaI to aIIow fI
for. designer in locating and sizing facilities.

Operator:EDDIE HUNTLEY REV. County:
ANSON
Date:
06/30/94
Distance to nearest residence (other
than
owner):
1200.0
feet
1. AVERAGE LIVE WEIGHT (ALW)
0 sows (farrow to finish)
x
1417
lbs. =
0
lbs
0 sows (farrow to feeder)
x
522
lbs. =
0
lbs
0 head (finishing only)
x
135
lbs. =
0
lbs
0 sows (farrow to wean)
x
433
lbs_ -
0
lbs
3552 head (wean to feeder)
x
30
lbs. =
106560
lbs
Describe other :
0
Total Average Live Weight = 106560 lbs
2. MINIMUM REQUIRED TREATMENT VOLUME OF LAGOON
Volume = 106560 lbs. ALW x Treatment Volume(CF)/lb. ALW
Treatment Volume(CF)/lb. ALW = 1 CF/lb. ALW
Volume = 106560 cubic feet
3. STORAGE VOLUME FOR SLUDGE ACCUMULATION NZ)r
Volume = 0.0 cubic feetECycJ,Sir��
4. TOTAL DESIGNED VOLUME
Inside top length (feet)---------------------
225.0
Inside top width (feet)------------------------
122.0
Top of dike elevation feet --------
99.9
Bottom of lagoon elevation (feet)------------
88.9
Freeboard (feet)-----------------------------
1.0
Side slopes inside lagoon) -------
3.0 : 1
Total design volume using prismoidal formula
SS/END1 SS/END2 SS/SIDE1 SS/SIDE2 LENGTH
WIDTH DEPTH
3.0 3.0 3.0 3.0 219.0
116.0 10.0
AREA OF TOP
LENGTH * WIDTH =
219.0 116.0
AREA OF BOTTOM
LENGTH * WIDTH =
159.0 56.0
25404 (AREA OF TOP)
8904 (AREA OF BOTTOM)
AREA OF MIDSECTION
LENGTH * WIDTH * 4
189.0 86.0 65016 (AREA OF MIDSECTION * 4)
CU. FT. = AAREA TOP + (4*AREA MIDSECTION) + AREA BOTTOMU * DEPTH/6
25404.0 65016.0 8904.0 1.7
Total Designed Volume Available = 165540 CU. FT.

5. TEMPORARY STORAGE REQUIRED
DRAINAGE AREA:
Lagoon (top of dike)
Length * Width =
225.0 122.0 27450.0 square feet
Buildings (roof and lot water)
0.0 square feet Describe this area.
TOTAL DA 27450.0 square feet
Design temporary storage period to be 180 days.
5A. Volume of waste produced
Feces & urine production in gal./day per 135 lb. ALW 1.37
Volume = 106560 lbs. ALW/135 lbs. ALW * 1.37 gal/day 180 days
Volume = 194650 gals. or 26022.7 cubic feet
5B. Volume of wash water
This is the amount of fresh water used for washing floors or volume
of fresh water used for a flush system. Flush systems that recirculate
the lagoon water are accounted for in 5A.
Volume = 0.0 gallons/day * 180 days storage/7.48 gallons
per CF
Volume = 0.0 cubic feet
5C. Volume of rainfall in excess of evaporation
Use period of time when rainfall exceeds evaporation by largest amount.
180 days excess rainfall = 5.0 inches
Volume = 5.0 in * DA / 12 inches per foot
Volume = 11437.5 cubic feet

5D. Volume of 25 year - 24 hour storm
Volume = 6.3 inches / 12 inches per foot * DA
Volume = 14411.3 cubic feet
TOTAL REQUIRED TEMPORARY STORAGE
5A.
26023
cubic
feet
5B.
0
cubic
feet
5C.
11438
cubic
feet
5D.
14411
cubic
feet
TOTAL 5187Z cubic feet
6. SUMMARY
Temporary storage period====================>
180
days
Rainfall in excess of evaporation===========>
5.0
inches
25 year - 24 hour rainfall==================>
6.3
inches
Freeboard===================================>
1.0
feet
Side slopes=================================>
3.0
: 1
Inside top length===========================>
225.0
feet
Inside top width======================- ====>
122.0
feet
Top of dike elevation=======================>
99.9
feet
Bottom of lagoon elevation==================>
88.9
feet
Total required volume=======================>
158431
cu. ft.
Actual design volume========================>
165540
cu. ft.
Seasonal high watertable elevation (SHWT)===>
0.0
feet
Stop pumping elev.====______________________>
96.3
feet
Must be > or = to the SHWT elev.==========>
0.0
feet
Must be > or = to min. req. treatment el.=>
94.9
feet
Required minimum treatment volume===========>
106560
cu. ft.
Volume at stop pumping elevation============>
106891
cu. ft.
Start pumping elev.=________________________>
98.2
feet
Must be at bottom of freeboard & 25 yr. rainfall
Actual volume less 25 yr.- 24 hr. rainfall==>
151129
cu. ft.
Volume at start pumping elevation===========>
148246
cu. ft.
Required volume to be pumped================>
37460
cu. ft.
Actual volume planned to be pumped==========>
41355
cu. ft.
Min. thickness of soil liner when required==>
1.6
feet
7. DESIGNED BY: ,�ci�� f� ,� C ,gPPROVED BY: �•
, ��
DATE: blylc/Cj� DATE: % 8/ �-
NOTE: SEE ATTACHED WASTE UTILIZATION PLAN
COMMENTS: 7ZIn jita QAcCL)L4R-nn0S FOR—,
EX FjVAT1ON Q F1LI- •Q ��

SHEET 1 OF 2
OPERATION AND MAINTENANCE PLAN
------------------------------
This lagoon is designed for waste treatment (permanent storage) and
180 days of temporary storage. The time required for the planned
fluid level (permanent and temporary storage) to be reached may vary
due to site conditions, weather, flushing operations, and the amount
of fresh water added to the system.
The designed temporary storage consists of 180 days storage for:
(1) waste from animals and (2) excess rainfall after evaporation. Also
included is storage for the 25 year - 24 hour storm for the location.
The volume of waste generated from a given number of animals will be
fairly constant throughout the year and from year to year, but excess
rainfall will vary from year to year. The 25 year rainfall will not
be a factor to consider in an annual pumping cycle, but this storage
volume must always be available.
A maximum elevation is determined in each design to begin
pumping and this is usually the outlet invert of pipe(s) from
building(s). If the outlet pipe is not installed at the elevation to
begin pumping, a permanent marker must be installed at this elevation
to indicate when pumping should begin. An elevation must be established
to stop pumping to maintain lagoon treatment depth.
Pumping can be started or stopped at any time between these two
elevations for operating convenience as site conditions permit, such as
weather, soils, crop, and equipment in order to apply waste without
runoff or leaching.
Land application of waste water is recognized as an acceptable
method of disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation. Care should be
taken when applying waste to prevent damage to crops.
The following items are to be carried out:
1. It is strongly recommended that the treatment lagoon be pre -
charged to 1/2 its capacity to prevent excessive odors during
start-up. Pre -charging reduces the concentration of the initial
waste entering the lagoon thereby reducing odors. Solids should be
covered with effluent at all times. When precharging is complete,
flush buildings with recycled lagoon liquid. Fresh water should not
be used for flushing after initial filling.
2. The attached waste utilization plan shall be followed. This
plan recommends sampling and testing of waste (see attachment)
before land application.
3. Begin temporary storage pump -out of the lagoon when fluid level
reaches the elevation 98.2 as marked by permanent marker. Stop pump -
out when the fluid level reaches elevation 96.3 . This temporary
storage, less 25 yr- 24 hr storm, contains 37460 cubic feet or
280202 gallons.

SHEET 2 OF 2
4. The recommended maximum amount to apply per irrigation is
one (1) inch and the recommended maximum application rate is 0.3
inch per hour. Refer to the waste utilization plan for further details.
5. Keep vegetation on the embankment and areas adjacent to the
lagoon mowed annually. Vegetation should be fertilized as needed
to maintain a vigorous stand.
6. Repair any eroded areas or areas damaged by rodents and
establish in vegetation.
7. All surface runoff is to be diverted from the lagoon to stable
outlets..
8. Keep a minimum of 25 feet of grass vegetated buffer around
waste utilization fields adjacent to perennial streams. Waste will
not be applied in open ditches. Do not pump within 200 feet of a
residence or within 100 feet of a well. Waste shall be applied in a
manner not to reach other property and public right-of-ways.
9. The Clean Water Act of 1977 prohibits the discharge of
pollutants into waters of the United States. The Department of
Environment, Health, and Natural Resources, Division of Environ-
mental Management, has the responsibility for enforcing this law.

SHEET 1 OF 2
SPECIFICATIONS FOR CONSTRUCTION OF WASTE TREATMENT LAGOONS
----------------------------------------------------------
FOUNDATION PREPARATION:
-----------------------
The foundation area of the lagoon embankment and building pad shall be
cleared of trees, logs, stumps, roots, brush, boulders,sod and rubbish.
Satisfactory disposition will be made of all debris. The topsoil from
the lagoon and pad area should be stripped and stockpiled for use on
the dike and pad areas. After stripping, the foundation area of the
lagoon embankment and building pad shall be thoroughly loosened prior
to placing the first lift of fill material to get a good bond.
EXCAVATION AND EARTHFILL PLACEMENT:
-----------------------------------
The completed excavation and earthfill shall conform to the lines,
grades, and elevations shown on the plans. Earthfill material shall
be free of material such as sod, roots, frozen soil, stones over
6 inches in diameter, and other objectionable material. To the extent
they are suitable, excavated materials can be used as fill. The fill
shall be brought up in approximately horizontal layers not to exceed 9
inches in thickness when loose and prior to compaction. Each layer
will be compacted by complete coverage with the hauling and spreading
equipment or standard tamping roller or other equivalent method.
Compaction will be considered adequate when fill material is observed
to consolidate to the point that settlement is not readily detectible.
NOTE THE SPECIAL REQUIREMENTS FOR PLACEMENT OF LINERS IN THE LINER
SECTION OF THIS SPECIFICATION. The embankment of the lagoon shall be
installed using the more impervious materials from the required
excavations. Construction of fill heights shall include 5 percent for
settlement. Dikes over 15 feet in height and with an impoundment
capacity of 10 acre-feet or more fall under the jurisdiction of the NC
Dam Safety Law. The height is defined as the difference in elevation
from the constructed height to the downstream toe of the dike.
Precautions shall be taken during construction to prevent excessive
erosion and sedimentation.
LINER: THE MINIMUM REQUIRED THICKNESS SHALL BE 1.6 ft.
------ --------------------------------------------------
NOTE: LINERS (PARTIAL OR FULL) ARE REQUIRED WHEN THE ATTACHED SOILS
INVESTIGATION REPORT SO INDICATES OR WHEN UNSUITABLE MATERIAL IS
ENCOUNTERED DURING CONSTRUCTION. A TYPICAL CROSS SECTION OF THE LINER
IS INCLUDED IN THE DESIGN WHEN LINERS ARE REQUIRED BY THE SOILS REPORT.
When areas of unsuitable material are encountered, they will be over -
excavated below finish grade to the specified depth as measured
perpendicular to the finish grade. The foundation shall be backfilled
as specified to grade with a SCS approved material (ie - CL,SC,CH).
REFER TO THE SOILS INVESTIGATION INFORMATION IN THE PLANS FOR SPECIAL
CONSIDERATIONS.

SHEET 2 OF 2
Soil liner material shall come from an approved borrow area. The
minimum water content of the liner material shall be optimum moisture
content which relates to that moisture content when the soil is kneaded
in the hand it will form a ball which does not readily separate. Water
shall be added to borrow as necessary to insure proper moisture content
during placement of the liner. The moisture content of the liner
material shall not be less than optimum water content during placement.
The maximum water content relates to the soil material being too wet
for efficient use of hauling equipment and proper compaction. Proper
compaction of the liner includes placement in 9 inch lifts and
compacted to at least 90 percent of the maximum ASTM D698 Dry Unit
Weight of the liner material. When smooth or hard, the previous lift
shall be scarified and moistened as needed before placement of the next
lift.
The single most important factor affecting the overall compacted perme-
ability of a clay liner, other than the type of clay used for the
liner, is the efficient construction processing of the compacted liner.
The sequence of equipment use and the routing of equipment in an estab-
lished pattern helps assure uniformity in the whole placement and
compaction process. For most clay soils, a tamping or sheepsfoot
roller is the preferable type of compaction equipment.
The soil liner shall be protected from the discharge of waste outlet
pipes. This can be done by using some type of energy dissipator(rocks)
or using flexible outlets on waste pipes.
Alternatives to soil liners are synthetic liners and bentonite sealant.
When these are specified, additional construction specifications are
included with this Construction Specification.
CUTOFF TRENCH:
--------------
A cutoff trench shall be constructed
shown on a typical cross section in
cutoff trench shall be determined by
materials.
VEGETATION:
under the embankment area when
the plans. The final depth of the
observation of the foundation
All exposed embankment and other bare constructed areas shall be seeded
to the planned type of vegetation as soon as possible after construc-
tion according to the seeding specifications. Topsoil should be placed
on areas of the dike and pad to be seeded. Temporary seeding or mulch
shall be used if -the recommended permanent vegetation is out of season
dates for seeding. Permanent vegetation should be established as soon
as possible during the next period of approved seeding dates.
REMOVAL OF EXISTING TILE DRAINS
-------------------------------
When tile drains are encountered, the tile will be removed to a minimum
of 10 feet beyond the outside toe of slope of the dike. The tile
trench shall be backfilled and compacted with good material such as
SC, CL, or CH.

SEEDING SPECIFICATIONS
----------------------
AREA TO BE SEEDED: 1.0 ACRES
USE THE SEED MIXTURE INDICATED AS FOLLOWS:
0.0 LBS. FESCUE GRASS AT 60 LBS./ACRE
(BEST SUITED ON CLAYEY OR WET SOIL CONDITIONS)
SEEDING DATES: SEPTEMBER 1 TO NOVEMBER 30
FEBRUARY 1 TO MARCH 30
0.0 LBS. RYE GRAIN AT 30 LBS./ACRE (NURSERY FOR FESCUE)
0.0 LBS. 'PENSACOLA' BAHIA GRASS AT 60 LBS./ACRE
(SEE FOOTNOTE NO. 1)
SEEDING DATES: MARCH 15 TO JUNE 15
8.0 LBS. HULLED COMMON BERMUDA GRASS AT 8 LBS./ACRE
(SUITED FOR MOST SOIL CONDITIONS)
SEEDING DATES: APRIL 1 TO JULY 31
0.0 LBS. UNHULLED COMMON BERMUDA GRASS AT 10 LBS./ACRE
SEEDING DATES: JANUARY 1 TO MARCH 30
0.0 LBS. RYE GRASS AT 40 LBS./ACRE (TEMPORARY VEGETATION)
SEEDING DATES: DECEMBER 1 TO MARCH 30
LBS.
APPLY THE FOLLOWING:
1000.0 LBS. OF 10-10-10 FERTILIZER (1000 LBS./ACRE)
2.0 TONS OF DOLOMITIC LIME (2 TONS/ACRE)
100.0 BALES OF SMALL GRAIN STRAW (100 BALES/ACRE)
ALL SURFACE DRAINS SHOULD BE INSTALLED PRIOR TO SEEDING. SHAPE
ALL DISTURBED AREA IMMEDIATELY AFTER EARTH MOVING IS COMPLETED.
APPLY LIME AND FERTILIZER THEN DISK TO PREPARE A 3 TO 4 INCH
SMOOTH SEEDBED. APPLY SEED AND FIRM SEEDBED WITH A CULTIPACKER
OR SIMILAR EQUIPMENT. APPLY MULCH AND SECURE WITH A MULCH
ANCHORING TOOL OR NETTING.
1. PENSACOLA BAHIAGRASS IS SLOWER TO ESTABLISH THAN COMMON
BERMUDA GRASS. WHEN USING BAHIA, IT IS RECOMMENDED THAT 8
LBS./ACRE OF COMMON BERMUDA BE INCLUDED TO PROVIDE COVER
UNTIL BAHIAGRASS IS ESTABLISHED.

Orientation:
110.0
105.0
100.0
95.0
90.0
65.0
Lower Left
30 Mesh Surface
Existing
Project: EDDIE HUNTLEY
Drawing: 4 888 NURSERIES
Number:
Location:
Bid Date:
Engineer:
Owner:
Estimator:
*--10�ation. 20.0
.su risen purr ace
Prepared by: using Sitework

'-----\107.mm
�
Dmulig,�srimoter
Plot of the contour data for the surface:
Existing
Drawing: 4 aeS NURSERIES
Sid Date:
Prepared bW: using Sitework

-�-? 1 c JA L c k o s s 5 SA=-r o a V 1 E W DP fA O f�-, .3`t Gtrz L A CROON
�7 R+-c µ'A RG r--- 1)tSIG*
&-v al E 1-kV-4-k y
L3oT70w� o A Suw��
EL>- V
U .S
B LDG.
P111150b FIDOR r--I6V,
ZIDT AL DSSI QK
5-To'R,AC,S 0,06V,
TOP oP bIKE
/ 99. q SLeV.
" 1?�U�kj OP DU7t I1s,9,
D ;Z 6.Ir.Y.
l%Goti N
su�poR't
C3v7T ovw El � • �
W14a0 At2aa,!5, ,Pr
41, N4Z.7a" (V, Wle-W, I ca G `r' w
>1cQ,VATIL
��� �,.: �w rN I �.av� t�,f..l �� �r�►c � I c.� � �a bW a
Gi�vr e�T t7 W r+-Ii c5 A re) vp,2
AAC1Tep-ML-

Orientation: -A
110.0
105.0
106.0
95.0
90.0
05.0
80.0
Lower Left
30 Mesh Surface
Balanced
Project: EDDI£ HUNTLEY
Drawing: 4 BOB NURSERIES
Number:
Location:
Bid Date:
Engineer:
Owner:
Estimator:
Prepared bW: using Sitework
:lination: 20.0
ow Mesh Surface

imeter
Plot of the contour data for the surface:
Balanced
Project: EDDIE HUNTLEY
Drawing: 4 ee6 NURSERIES
Number:
Location:
Bid Date:
Engineer:
Owner:
Estimator:
Prepared bg: using Sitework

41
.09
8T.59
10 .69
E102.22
102.22
101.72
102.22
102.22
101.72
102.22 '101.89
102. 22
102.89
101.72
_ 102.22
102.22
101.E
.89
DaWlight3
Plot of all data for the surface:
Balanced
Project: EDDIE HUNTLEY
Drawing: 4 888 NURSERIES
Number•
Location:
Bid Date:
Engineer:
Owner:
Estimator:
Prepared bW: using Sitework

. 89
W. Oa r
Plot of the sloping lines for the surface:
Balanced
Project: EDDIE HUNTLEY
Drawing: 4 888 NURSERIES
Number:
Location:
Bid Date:
Engineer:
Owner:
Estimator:
Prepared bW: using Sitework

a. 22
2.22
11.72
12.22
02.22
01.72
02.22
102.22
101. 72
102.22
102.22
Plot of the eloping lines for the surface:
Balanced
Project: EDDIE HUNTLEY
Drawing: 4 888 NURSERIES
Number:
Location:
Bid Date:
Engineer:
Owner:
Estimator:
Prepared icy: using Sitework

Fill shrink/swell percent: 20.00 Cut shrink/swell percent: 0.00
Iterating to balancing within 10.0 cubic yards...
delta
Cut
Fill
CUT - FILL
0.00
6905.68
6905.76
-0.08
-0.00
3279.79
13254.12
-9974.32
0.00
3279.77
13254.19
-9974.42
-2.04
6754.20
7075.05
-320.85
-2.10
6902.57
6909.17
-6.61
--2.11
6905.72
6905.72
-0.00
Lower "Proposed" by 2.11 feet.
New surface called "Balanced" has been created.
Project: EDDIE HUNTLEY
Drawing: 4 888 NURSERIES
Number:
Location:
Bid Date:
Engineer:
Owner,
Estimator:
Prepared by: using Sitework

97.39
........................ ............ ..............................................� .. 1
•i.................................... 1 6 0 . 9
93: 85.................. .
8
•88':'89...... BB.69; -Y9
99/89 ...........
100.8
...!
.09
9'7.69
10 . 69
101.89
101.E
fim ier
--�
E102.22
102.22
101.72
102.22
102.22
101.72
(102.22
102.22
101.72
102.22
102.22
DaJlioht
6
: EDDIE HUNTLEY: 4 888 NURSERIES: 811anced
17 JUN 94 2:44 PM

119.00
1
Prapaged
105.00
100. 00
95.00
90.00
86.00
60.00 `
(9B.56,197.66)
<367.08>
(465.32,213.19)
: EDDIE HUNTLEY: 4 88B NURSERIES
17 JUN 94 2:44 PM

U. S. Department of Agriculture
Soil Conservation Service
HAZARD CLASSIFICATION DATA SHEET FOR DAMS
IBC-ENG-34
September 1980
File Code: 210
Landowner County An ct%n__
Community or Group No.
F5
Conservation Plan No.
Estimated Depth of Water to fop of Dam 11 Ft. Length of Flood Pool 14 U - Ft.
Date of Field Hazard Investigation_ _ 7/5/94
Evaluation by reach of flood plain downstream to the point of estimated minor effect
from sudden dam failure.
:Est.
Elev. s evation
Kind of
:Improvements: of Breach
Reach:
Length: -Width: Slope: Land Use
Improvements
Above :Floodwater Above
Flood Plain: Flood Plain
Ft.
Ft.
Ft. Ft.
•
1 .
400
Ut-.-..t x. Ripwiap
100 2.5 vegetation,
SM19 GPM
SR 11240 31Y,
culvert under
.
2
4400
Mods & Riparilm�
210 1.2 : Vegetation
_cR 1126. U;gMV r7
201 span woad
— — _ 5
.
3
5200
75D :1t0. 2 : Vegetation -
_ -- — - -
concrete bridge
S. Fork Jcrix n-_
.
-
Describe
pateitn al'/foFoMssrS?x ifieLERnd taQwamagepEioEEE>Tsving
or probable future downstream
improvements
from a sudden breach _ SLuft
potential fcr lcss cf life_ or Vic, gggiLiM or _
POYUnt_ia? daantreetn _ _ da MM CQUId he agmtAnLial. .1MR of arnotir,1ifv,
& dagradaticn o0 water
Hazard Classification of Dam (a, b, c) (see NEM-Part 520.21) a
Dam Classificaticn (1, II, III, IV, V)_ -n - (tip Trea-Taqmxi=,� mass -TT) -
Date
Date 8 4
NOTE: 1. Instructions on reverse side.
2. Attach additional sheets as needed.

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Bill Holman, Secretary
Kerr T. Stevens, Director
December 18, 2000
1 UNTLEY-VERNON FARMS INC
112 WILLIAMSBURG LANE
WADESBORO NC 28170
A��
NCDENR_..._...._
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Application No. AWSO40009
Additional Information Request
Huntley -Vernon Farms Inc
Animal Waste Operation
Anson County
Dear Huntley -Vernon Farms Inc.:
The Non -Discharge Permitting Unit has completed a preliminary engineering review of the subject application. Additional
information is required before we can continue our review. Please address the following by January 17, 2001:
Please revise the calculations of Plant Available Nitrogen (PAN) and Waste produced per year based on the
Natural Resources Conservation Service Conservation Practice Standard Waste Utilization Code 633-45,
the values submitted seem to be below the recommended values. A copy of Code 633-45 is included for
your use.
Please note that all IN'UP revisions must be signed and dated by both the owner and the technical specialist. Please
reference the subject permit application number when providing the requested information. All information should be signed,
sealed, and submitted in duplicate to my attention at the address below. The information requested by this letter must be
submitted on or before January 17, 2001 or the Division will return your application as incomplete in accordance with 15A
N.C.A_C. 2H .0200 and your facility will be considered to be operating without a permit.
Please be advised that operation of the subject animal waste management system without a valid permit is a violation of North
Carolina General Statute 143-215.1 and will subject you to the enforcement authority of the Environmental Management
Commission.
If you have any questions regarding this request, please call me at [phone], extension 544.
Sincerely, ,(
Stephanie Milam
Environmental Engineer
Non -Discharge Permitting Unit
cc: Fayetteville Regional Office, Water Quality
Robert E. Her -ton. Jr.. USDA-NRCS
Permit File
1617 Mail Service Center, Raleigh, North Carolina 27699-1617 Telephone [phone] FAX [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/ 10% posi=sumer paper

Rev. Ju v 1996 633-45
Swine Anaerobic Lagoon Liquid Land Application Spreadsheet
This sprmadshcct uses values from e3istiag NaU/NCDA data base to calculate the f= mTm-r nur ienS applimEon rates and
land arras n=ded for agronomic usage of irristed swine anaerobic lagoon liquid. Valuts in r= ils 125-PS6 mprest.nt imp=
which =;.d to be entered to us.-- this spr=dshcct_ Valuzz in =Us C2-L% are typical values which may be usad if more spe;:u"=
information is not available. If anual lagoon liquid nutrica ana3yses are used, then a corresponding change in lagoon-Iiq>xid
volumes .should also be entrrtd_ Application rates and land areas are ra Mated for a range of fmrtiliaatioa rates- Actual
f_sti!�-%tion rates based on crop yield may be entered into cells J66469 with the results cal=ulatcd in columns W and AE in
Table C. The sprradsht:_t also campures herd live vi-might equivalcnrs, lagoon cspaarirs, and --s6a►cd annual lagoon liquid
volumes io be land appii;.d -- -
]
7yaieat
Act at
#
]
[
---------------------
Wean-
F" dr Gitt
------------------
boar
----Farrow- to---
----------------------------------------
Wean-
Faedj Lilt
tenor
---- Farrar-tr---
[
[
[
feWr
-Fin
Dev
stud
Wean
Feed.-
Fin
Faadr
-Fin
Der
Steil
Wean
Frwdr
Fin
[
]
-------------------------------------------------------------------------------------------------------------------------
-----per head cam----
-per active sow
-----per hrad cap-----
-per arive
scr-
#
] Anneal live initial:
10
50
50
250
1D
5o
50
250
[
the ]
# ere i gn :: final:
50
22D
Z50
550
50
M
250
55D
lira [
aea:%:
3D
135
15D
4.0
kn
522
1G17
3D
135
15D
400
GT..3'
522
1G17
lea [
j :roue per year:
6'
3
2
1
2
2
2
6
3
2
1
2
2
2
[
9, /yr #
] Days per liro=:
49
125
11.0
365
11
63
168
49
ics
140
365
11
E3
163
darvgro= [
[ Lsoaan linuid_caaacity:
(oafs
rut inclu%e free3oard or
25-yr sto-a
storage)
s
[
# design treatment:
30
135
150
ZDD
229
3"
1417
30
135
150
200
2D9
348
14147
ft3/can cw [
] Sludoe Storage:
15
68
75
1DD
1,"
174
7D8
15
68
75
100
1."
174
7W
1:3/an cap [
] % =Porary storage:
15
68
75
200
217
Z61
7D8
1S
68
75
2D0
217
2b1
70S
ftUarn cap #
[
60
27D
300
500
f30
7E3
ZM
60
4T0
3a0
5D0
650
M
ZM
ft3/an cap [
j Lao-nm liquid a.^_.jwistim:
[
# as.-u.-e We- urine:
.30
1.:
1.5
4.0
4_3
5
1G
-30
1.1.
1.5
4L.0
4-3
5
U
gal/ar✓day [
[ e=e" aster usage:
.20
.9
1.D
2-7
2.9
3
9
.ZD.
.9
1.0
2.7
2-9
3
9
gal/aNday ]
# surface rain Surplea:
.11
-5
.5
1.4
1.6
2
5
.11
.5
.5
1.4
1.6
2
5
gal/an/day ]
# total:
.61
2.7
3.D
Z A
8.3
11
29
-61
2-7
3.0
8.1
t.5
Al
29
sal/an/day [
# Lagxn liquid tc:aE mnriant
anaEysis:
[
# 'Fat M-
1sd
136
136
68
91
91
136
136
136
136
68
91
91
*3d
13c/ar in [
] KY3k:
32
92
S2
82
i2
b2
52
52
52
92
E2
52
SZ
E2
S Y or ten #
] P2^5:
n
!Z
n
Z6
n
35
53
53
53
53
26
35
35
53
lot/a=-in [
yZ.�":
M
1Z3
1=3
67
IS
89
1M
113
1n
TM
67
89
Sa
113
Ex/a=-in ]
]
=irm-sli:at rate:
-50
.50
.50
.50
.50
-50
-50
..5o
.50
.50
.50
.50
.50
.50
r
[
[ Plan- rutrient availability
=efficiasnts:
Or= a=Hmation
=thud
b=)
[
] U:
.50
.50
.50
-50
.50
.50
.50.
.50
.50
.50
.50
-.50
.50
.50
]
] P2:S:
.7D
_70
.7D
_7D
.n
.7-0
--M
.7D
.7D
.7D
.7D
.7D
.7D
.70
[
] tom:
_73
.7o
_7D
_7D
.7D
.70
.7a
_7D
.7D
.7D
.7D
.70
.70
.70
]
] Aaplira:ion teemed War
[
------------------- N-------------------
PSr
# soil iniv=iars: .95
.37
.37
.57
.57
.57
-97
.97
.W [
]
;
Z�"
• lba/aC"t-irC?+ ]
[ sail _U
.79
.79
.79
.79
.79
.79
.79
.75 j
[
;gM s
0-2266
■ US/ -- in= [
] b.-oaccsst: .15
.:6
.:6
.G6
...d
.=.6
_66
..6
.70 #
] Ebl= Pala z
27.15:
• lba/act a -mean [
] ir-igatiar .50
.50
-50
.51)
.50
.5D
_50
.50
.70
►
- •��
]
] :-ao fe':ill:anion tI:
50
lba/ac/yr #
j raze: P2:::
2D
lbs/a:/yr [
j t2`:
SD
l9t/ac/yr [
5--DE ozu-_ for r: J *r - -

533-L6
Rev. JLly
Table 1U. SWINE AMAEMIC LAGOON LIQUID FERTILIZR WJTRIEMTS •
Type Animal
Animal Unit
Total Anaerobic
Total L89=n
Kent
Plant
Total
Plant
*f Unit
Equivalent
Lagoon Liquid
Liquid
Nutrient
Nutrient
Nutrients
Yutrnc
►roa Lion
Live Weight
capacity.
Surplus,'
Availability
irr•ipat.-
Unit •-
---------------
ft3/
per animal
Coefficients
-------------
init final mean
animal unit
unit/year
L
----------------
------------
inrigntsd
lba/
Ibs/ ani
single 2-stage_--. acre-_
'-'•
acre
acre ass
--------------------------------------------------------------------------------------------------------------------------
------ Lis-------
stage 1st • 2hd
gals iris
inch
lr,�li " ` y
iieaniing-to per
IC SD 30
60 45 '-15
191 .0070
M
.50
136
68
Feeder hand
►Z5
.70
53
37
crpec i ty
_.. _-
- _
120
- .70
133
93
Feeder -to per
5D Z2D 135
Z7D 2D0 7D
W .034
a
.So
136
68 ;
F i ni slt head
PZZ
JD
53
37
capacity
QD
.70
133
93
Gilt per 5D 250 15o 300 M
75 I015 -D37 Y
.5D
136
6E
i
Dire l OP MT head
P205
.70
53
37
capacity
L20
.n
133
93
Bear stud per ZSO 55D 400 500 375
125 2959 .11 Y
.50
68
34
t
bead
P2C5
.70
26
19
capacity
C20
.70
67
47
Farrow -to per 4 650 435
215 3203 .12 Y
.50
91
:5
5
lieanling active
P2m
.70
35
25
2
saw
120
.70
89
62
7
Farrow- to per S22 71_3 SO
260 3E61 .14 F2�
91
as
16
Feeder active
.50
35
25
=
sou
IQO'
.TO
89
62
t
Farrow -to per 1417 ZLT3 2125
708 10473 .39 Y
.50
136
68
Finim active
FZ:a
.70
S3
37
ew
m
.70
in
93
;
• Refererses: Depts of Biological and Agricultural Engineering, Animal Science; North Caroline State University;
."7�
AOreraic Division, North Carolina Depsrtsrnnt of Agriculture
Assumes LDO-Lb sow and boar an Limited feed,
3-wE old wasnling, 50-Lb faader pis, 22D-Lb
market hog and 20 pi Qs/et
Estimated total lagoon liquid In=ludes total
liquid mersre plus overage arrast
rsinfa[l surplus in=idental to last
sus face. does not a`o:n: for seepage.
-�
"'• Irritated- sprinkler irrigated liquid uricoversd for I aimt6 or Longer.
Table 18'. LAND APPLICATION OF SWINE AMAERMIC LA=C* LIQUID •
Type Anizel
Rate-
Lagoa* Liquid Aroliati*n Rate we
Miniva lard Ares for Liquid Appliration `
of Unit
Liaitir+2
------------------irrigated------------------
--------------------
irrisstm*--------------- --
Prod :ion
Nutrient
----------------
Un/acre/ ear----------------
------------------ lba/scre/year---------- -----
unit
N
50
100
150
2DO
250
3M
350
400
50
100
156
200 25D 300 350 40
F205
20
40
60
so
100
120
14,0
160
20
4O
60
80 10O MO IQ 16
----------------------------------------------------------------------------------------------------------------------------
10
SD
IDO
150
20D
250
300
350
QC
50
1D0
150
200 250 30D 350 40
-----------------lrnches/year-----------------
--------------
-acres/animal unit............
wea.-+l i ng- to per
M
.73
1.5
2-2
2.9
3.7
4.4
5.1
5.9
.M%
.004E
.0=
Aw/. .DC19 .0016 .0014 AM
Feuer head
P2-,s
_54
1.1
1.6
2_2
2.7
3.2
3-8'
43
.013
.0065
.OD:3
.0033 -M26 .D= .0019 AM
csgnci:y
120
.54
1.1
1.6
7-1
2.7
3_2
3.7
43
.013
.0066
.004.E
.MM .OU6 .0022 .0019 _0014
Feeder -TO per
.1I
.73
1-5
2.2
2.9
3-7
L.4
5.1
5_9
.047
.CZ3
.016
.012 _DM .0= .0066 .DM
Finish head
P=
JA
1.1
1.6
2.2
2.7
3.2
3.8
43
.00
.M
MI
.016 Ar..3 .011 .OM .0071
capacity
=
t54
1.1
1.6
2.1
2-7-
3.2
3_7
4.3
.M4
.C32
.CZI
.016 .013 .M1 .OM .0=
Gil; per
N
.73
1.5
2_2
2_9
3.7
4.4
5.1
5.9
.051
.D25
.017
_013 .010 .00ES .DM .00b
Deveiaast head
F2z
.0
1.1
1.6
2.2
Z-7
3_2
3.E
43
.069
.035
.M
_017 .014 .012 .OM AW,
r_acns=iry
.0
1.1
1.6
2.1
2.7
3.2
3.7
43
.M
-M5
A23
.017 .014 .012 .MD -OW,
soar par
Y
1.5
2_9
4.1.
5.9
7-3
8-8
10
12
.074
.l=37
.025
.019 -015 .MZ .011 .DM
Staff head
P2Z
1.1
2.2
3.2
43
5.4
6-5
7.6
9.6
.10
.050
.M
M 5 .CQO .017 -014 ,II::
topecity
120
1.1
2.1
3.2
4.3
5.4
6.4
7-5
9-6
.10
.L51
.CU
-D25 ,DZD .017 .015 ,II..
Farrow -to par
Y
1.1
2_2
33
4.4
5-5
b.6
7.7
9-3
-11
.M4
.06
_CZ7 .CZI _CM3 .015 .O`.:
iiesni-isns active
P2=5
.91
1.b
2.4
3_2
4-D
4.9
5.7
6-5
.15
.M
.Dr*9
A36 -CZ9 -C24 -C21 0:1
saw
A=
_EII
1_6
Z.4
3.2
4.0
4-8
5.6
6_1.
.15
.073
.069
.037 _029 ,C24 .021 -011
Farrar:* per
M
1.1
2.2
3.3
4.4
5_5
6.6
7-7
Z-8
.13
.M5
.043
.032 .M .t+cZ .011
Feeder active
P225
.31
1_6
2.4
3.2
4.n
4.9
5-7
6_5
.1s
.OEE
.259
.0" .05 .CZ9 -Or _
saw
1=
.W
1.6
2.4
3.2
4.0
4_E
5_6
6.4
-18
.08E
,L59
.0" .M5 .Z29 -L2 =
Farrow-t* her
M
.73
1_5
2.2
2.9
3.7
4.4
5.1
5.9
.sue'
26
.18
_13 .11 AM .M
Finiset active
P225
.S4
1,1
1.6
2.2
2.7
3.2
3_3
4.3
,72
.36
.24
.1E .% . .IZ " .10
sow
120
_54
1.1
1.6
2_1
2.7
3.2
3.7
43
.72
.36
.24
.18 .11. .12 .10 -_
` Referenees. Dee:3
of =iologi:ai iAgriculturat Engineering, Soil Science.
Lrmv
faience;
Mortis Caroline St Univ; Jan 1945
M fertilizz:ion
rste sheuid
be cauistent with realistic crop Yield.
Y lea=ins and deni=rification
re P22S
soil
iwaaeilizatisn u%g=Mrr.Md
far.

' R F-C G:IV ED�l
BROWN CREEK Soil Water Conservation District USDA Natural Resources Conservation Service
WASTE UTILIZATION RLANalemuoiry
Animal waste must be land applied at a specified rate to prevent pollution of surface water and/or groundwater.
Plant nutrients in animal waste should be used to reduce amounts of commercial fertilizer required for crops (in
the fields where the waste is applied). This waste utilization plan uses nitrogen as the limiting nutrient_ Waste
should be analyzed before each application cycle. Annual, soil tests are strongly encouraged so that all plant
nutrients can be balanced for realistic yields of the crop to be grown.
Several factors are important in implementing your waste utilization plan in order to maximize fertilizer value of
animal waste; and, to ensure that it is applied in an environmentally safe manner:
1). Always apply waste based on crop needs and nutrient content of the waste. Do not apply more nitrogen.
than the crop can utilize.
2). Soil types are important... they have different infiltration rates, leaching potentials, cation exchange
capacities, and available water holding capacities.
3). Normally waste shall not be applied to land erodingat greater than 5 tons per acre per year. With special
precautions, waste may be applied to land eroding at up to 10 tons per acre per year.
4). Do not apply waste on saturated soils, when it is raining, or when the soil surface is frozen. Any of
these conditions may result in runoff to surface waters which is not allowed under NCDWQ regulations.
5). Wind conditions should also be considered to avoid drift and downwind odor problems.
fi). To maximize the value of nutrients for crop production and reduce the potential for pollution, waste should
be applied to a growing crop, to bare ground not more than 30 days prior to planting, or, to a forage within
30 days of breaking dormancy. Injecting waste or disking will conserve nutrients and reduce odor
problems.
This plan is based on the waste application method shown. Nutrient levels for different application methods are
not the same; therefore, changing application methods in the future will require a change or revision of this plan_
Estimated acres needed to apply the animal waste are based on typical nutrient content for this type of opera-
tion. Actual acreage requirements should be based on the waste analysis report from your waste management
facility. In some cases a plant analysis may be beneficial- and, allow additional waste to be applied. The land
area receiving waste should be flexible enough to accommodate changing waste analysis content and crop type.
Lime must be applied to maintain pH in the optimum range for the crop being managed and grown.
This waste utilization plan, if carried out, meets the requirements for compliance with 15A NCAC 2H.0217
adopted by the Environmental Management Commission.
Page 1 ANSON COUNTY NC

BROWN CREEK Soil Water Conservation District
USDA Natural Resources Conservation Service
WASTE UTILIZATION PLAN.
Estimated Annual Waste & Nutrient Production
WASTE
APPLY DESIGN SIZE ANNUAL WASTE PLANT AVAILABLE
ANIMAL PROD. UNIT TYPE WASTE SYSTEM METHOD # CAPACITY PRODUCED NITROGEN (PAN)
• • • • • • - - • W 3552 0.007 acre=inch/unit 68 6jac.-in.
Waste Generation Figures from MRCS Tech. Guide - Practice Code 633
Amount of Waste Produced per Year* 24.9 acre -inch approx. 675157 gallons
Amount of PAN Produced per Year 1691 Ib. Plant Available Nitrogen
Amount of waste produced per year does not include excess wash water or run-off ff any!?.
A I in_q all this waste in a timely manner is a big 4ob... re uirin time,planning and appropriate equipment
The following land/field acreage in Table 1 and Table 2 will be needed for waste application based on crop grown
and waste application method listed. See Appendix 1 for a list of Soil Types, Realistic Yield Expectations, N
Application rates, and Commercial N use assumptions used to develop this plan. See recordkeeping FORMS
(attached) for required waste utilization records that need to be maintained.
Acres Owned by Producer
LB. N Total
Tract Field Cron Soils Acres lAc.- N 1 Utilized acre -inch ADDIV Month
3000
1A
Hybrid Bermuda Hay
246E
1.0
196
196.0
2.9
May-Aug31
3000
1 B
H brid Bermuda Hay
246E
1.0
196
196.0
2.9
May-Aug31
3000
2
Hybrid Bermuda Hay
575E
5.7
245
1396.5
20.5
May -Sept
3000
-1A
Ryegrass overseeded
246E
1.0
100
100.0
1.5
See Note-App1
3000
. -1 B
Ryegrass overseeded
246E
1.0
100
100.0
1.5
See Note-Appt
3000
--2
Ryegrass overseeded
575E
5.7
50
265.0
4.2
Sept -April
" This N is from animal waste only. (TOTAL 1 7.7 acs 1 _ 2274 lb.
Indicates that this field is being overseeded (i.e. interplanted), or, that winter annuals follow summer annuals.
If nutrients from other sources such as commercial fertilizer are applied, they are accounted for in Appendix 1.
CAUTION: P and K may be over applied while meeting N requirements. In the future, regulations may require fanners in some parts of
North Carolina to have a nutrient management plan that addresses all nutrients (N, P & K). This plan only addresses Nitrogen.
Acres with Agreement or Lona Term Lease
LB. N Total
Tract Field Crop Soils Acres lAc.• N I Utilized acre -inch Apply Month
No rented land for waste utilization
'See footnotes for Table 1. TOTAL acs lb.
Page 2 ANSON COUNTY NC

BROWN CREEK Soil Warer Conservation Discricc
USDA Natural Resources Conservation Service
WASTE UTILIZATION PLAN
Totals from Table 1 & Table 2
Acres Lb.. N Utilized
Table 1 7.7 acs 2274 lb.
Table 2 acs lb.
TOTAL 7.7 acs 2274 lb.
Amount of N Produced 1691 lb.
"'"<Deficit> of PAN -583 lb.
"Must be 4 (zero) or <Deficit> in order to utilize all the animal waste N produced!
Table 1 & 2 Notes: - Acres shown are considered to be useable acres... excluding required buffers, filter strips, odd areas,
and perimeter areas where waste cannot be applied or equipment limitations may preclude full application
rates. Actual field acreage may, and likely will be, more than acres shown in the tables.
- See the attached map(s) showing fields referenced in these tables.
- The producer and waste applicator are responsible for ensuring that spreader (or irrigation) equipment
is calibrated, operated properly, and applies the correct rates to the acres shown in the tables. Failure
to apply recommended rates and amounts of nitrogen shown in the tables may invalidate this plan.
Important information for Application of Liquid Animal Waste
Refer to Waste Storage Facility Design/"As Built" Drawings or OEM Plan for amount of temporary
storage time, start pumping elevation & stop pumping elevation.
Irrigation/application rates should not exceed the intake rate for the soil at the time of irrigation... or runoff and ponding can occur.
The irrigationiapplication rate is controlled by initial soil moisture content, soil structure, soil texture, irrigation water droplet size,
and organic solids. The application amount should not exceed the available water holding capacity of the soil at the time of
irrigation nor should the plant available nitrogen (PAN) applied exceed the nitrogen needs of the crop.
The producer and irrigation designer is responsible for ensuring that an irrigation system is installed to properly irrigate animal
waste on the acres shown in Tables 1 & 2. Failure to apply recommended rates and amounts of nitrogen shown in the tables
may invalidate this plan. Application of liquid waste by other methods (honey -wagon, etc.) is the responsibility of the producer.
The following information is provided (bv soil tvpe and crop) to plan and evaluate liquid waste application
schedules. These figures represent optimum irrigation or application rateslfreauencies to meet crop water.
needs and prevent water runoff.
Soil Type Crop
575E Permanent Grass
246B Permanent Grass
Min. Irreg..
Frequency
Days Apply Rate
4 0.5 inihour
4 0.4 in/hour
" Apply Amount
0.5 inches
0.5 inches
From MRCS Tech. Guide, Section li - ENG - Irrigation Interpretations
This is the minimum rest period in days between irrigation on the same land area under optimum conditions.
" This is the maximum application amount allowed for the soil assuming nitrogen amounts for the
crop are not over applied. in many cases, the application amount shown cannot be applied due to
the nitrogen limitation. This maximum apply amount can be applied under optimum soil conditions.
Page 3 ANSON COUNTY NC

BROWN CREEK Soil Water Conservation District USDA Natural Resources Conservation Service
WASTE UTILIZATION PLAN.
Sludge:
This waste utilization plan must contain provisions for periodic land application of sludge at agronomic
rates. Sludge will be nutrient rich and require precautionary measures to prevent over application
Broadcast Soil Incorporated
Estimated Annual PAN from Sludge: 270 lbs. N 320 lbs. N
5yr Sludge Accumulation: 1350 lbs- N 1598 lbs. N
Based on a 5 year sludge removal schedule, estimated land area required for sludge disposal is-
7.5 acres of grass based on an application rate of 180 lbs. N per acre
20.0 acres of corn/soybeans based on an application rate of 80 lbs. N per acre
All the above figures are only estimates. Actual PAN and land area needed could vary 254 cr more depending
on sludge nutrient analysis. soil types. crop, realistic yield. and application method. sludge
disposal on a schedule other than every 5 years would drastically alter these estimates
Contact your technical specialist at the BROWN CREEK Soft & Water Conservation District - Natural
Resources Conservation Service (formerly the Soil Conservation Service) Office in Wadesboro, (704)
694-2710, when you receive a waste analysis report. Request assistance calculating
allowable application rates and amounts prior to applying waste.
Operation constructed to NRCS design and specs, and certified (0.200) 1/95. Acreage estimated and irrigation
_parameters provided for underground main/hydrant irrigation system design. Field acres in this plan are based
on effective irrigated area from irrigation design as plan was amended 3/24/98. Some woodland being irrigated
outside effective area (60% radius) for some gun sets. Additionally, some small amount of nutrients applied
and not accounted for outside effective irrigated area. Waste application equipment in place on farm.
NOTE: Plan revised 1116/01 to calculate Plant Available Nitrogen (PAN) per NRCS Practice Standard 633 for
permitting process. _
Page 4 ANSON COUNTY NC

�' +-. ��./:�.'� Z�:j' 1 C � } � SFr. �,�. �K:•,rli',., �7 � '� ;
_`+�•�; �.�r r S�� r� ..f�F�• 1-�t.'-,�•�j;, � �• ,�' Z� � •'r
.y�',�!i7-w*� :si. �` !f'iS Sr •?"4 1.. r•' '..'-f ��i1�i
t. L'• _ 1 �' � '- I `` r ,. HUNTLEY—VFRNON `�r
ZaOFARMS T r,
•'j:f �� ;. .,AIV MnP FARM# 2S06
TRACT# 30O0
Ap
ti t_�q 7*J�..
.•zr'�_:,- ~� � '•� * +-� - - d.4 �4a cif r � �.s•-fir'-� .,, ;•
iVGi} �zti 7 I2' , {�- •• }+� s ti;�n .�r ra." -• iio�pC i
r s�+�i ! �' _ w 1 ',y, �L•2 .�•� � � � r�+.-'=r [ai�-`:r �.� F,4t�,^v'� r• f 1.
s' CRP . ? N�� x. -v �';u.< _ •1 ° t.
tb w . I 'v_.tit r ' •, 1: .T.. t
CL
60
' Y�.•, � •alb• �Z� : • ! ��- �, •' � ••^•*`
:�:'�� ���P,�,Q�,y� ., yr. ''' �+`-'t"•_'
yA
1V
..N - I.\� , /// ` .}tea-�,T}l��t .7.+�. r ' �'r•
IP
:t•..� ��`-' -..- it\'4+.- � - 'r�' :'�flr`1 ��' >,(�, ;,_.� .�t��? � -� -
�TC' T:;_;�� Ar` ! �, - ,' r'r a39� •r I� i.Sol-
��
oil ''f j� Y 1 ~ ` ` 1.
Jam•:^i f7 YC�I Jd�l[ ��)f • _� n ' ,
! .ORYRI ;r

BROWN CREEK Soil Water Conservation District USDA Natural Resources Conservation Service
WASTE UTILIZATION PLAN-
1. Animal waste shall not reach surface waters of the state by runoff, drift, manmade conveyances, direct applica-
tion or direct discharge during operation or land application. Any discharge of waste which reaches surface water
is prohibited.
2. There must be documentation in the design folder that the producer either owns or has an agreement for use
of adequate land to properly apply the waste. If the producer does not own adequate land to properly dispose
of waste, he/she shall provide a copy of a written agrreement with a landowner who is within reasonable proximity,
allowing use of their land for waste application. The owner of the animal facility is responsible for securing an
updated Waste Utilization Plan when there is a change in the operation__.. such as increased animal numbers,
method of waste application, or change in available land for waste utilization.
3. Animal waste shall be applied to meet, but not exceed, the Nitrogen needs for realistic crop yields based on soil
type, available moisture, historical data, climate conditions, and level of management, unless there are regulations
that restrict the rate of application of other nutrients.
4. Animal waste may be applied to land eroding less than 5 tons per acre per year. Waste may be applied to land
eroding at 5 or more tons, but less than 10 tons per acre per year providing grass filter strips are installed where
runoff leaves the field. (See FOTG Standard 393 - Filter Strips].
5. Odors can be reduced by injecting waste or disking after waste application. Waste should not be applied
when the wind is blowing.
6. When animal waste is to be applied on acres subject to flooding, it will be soil incorporated on conventionally
tilled cropland. When applied to conservation tilled crops or grassland, the waste may be broadcast provided the
application does not occur during a season prone to flooding. (See "Weather & Climate in North Carolina" in
NRCS Field Office Technical Reference File - ENVIRONMENT for guidance).
7. Liquid waste shall be applied at rates not to exceed the soil infiltration rate such that runoff does not occur offsite
or to surface waters and in a method which does not cause drift from the site during application. No ponding
should occur ... to control odor and flies.
8. Animal waste shall not be applied to saturated soils, during rainfall events, or when the surface is frozen.
9_ Animal waste shall be applied on actively growing crops in such a manner that the crop is not covered with waste
to a depth that would inhibit growth. The potential for salt damage from animal waste should also be considered_
10. Waste nutrients shall not be applied in fall or winter for spring planted crops on soils with a high potential for
leaching. Waste nutrient loading rates on these soils should be held to a minimum and a suitable winter cover
crop planted to take up released nutrients. Waste shall not be applied to crops more than 30 days prior to
planting, or to forages more than 30 days prior to breaking dormancy.
11. Any new swine facility sited on or after October 1, 1995 shall comply with the following: Waste application
cannot occur within 50 feet from a residential property boundary; a perennial stream, river, canal or irrigation ditch.
For other animal operations or swine facilities sited before October 1, 1995 - waste application cannot occur within
25 feet of perennial waters [See FOTG Standard 393 - Filter Strips], NOTE: Local ordinances may preempt this.
12. Animal waste shall not be applied closer than 100 feet to wells.
13. Animal waste shall not be applied closer than 200 feet of dwellings other than those owned by the landowner.
Page 5 ANSON COUNTY NC

BROWN CREEK Sail Water Conservation District USDA Natural Resources Conservation Service
WASTE UTILIZATION PLAN.
I4. Waste shall be applied in a manner not to reach other property and public right-of-ways.
15. Animal waste shall not be discharged into surface waters, drainageways or wetlands by a discharge or by over -
spraying. Animal waste may be applied to prior converted wetlands provided they have been approved as a land
land application site by a "technical specialist". Animal waste should not be applied on grassed waterways that
discharge directly into water courses, and only then at agronomic rates provided the application causes no run-
off or drift from the site.
16. Domestic and industrial waste from washdown facilities, showers, toilets, sinks, etc., shall not be discharged into
the animal waste management system_
17. A protective cover of appropriate vegetation will be established on all disturbed areas (lagoon embankments,
berms, pipe runs, etc.). Areas shall be fenced, as necessary to protect the vegetation. Vegetation such as
trees, shrubs, and other woody species, etc_ are limited to areas where considered appropriate. Lagoon areas
should be kept mowed and accessible. Berms and structures should be inspected regularly for evidence of
erosion, leakage, or discharge_
18. if animal production at the facility is to be suspended or terminated, the owner is responsible for obtaining and
implementing a "closure plan" which will eliminate.the possibility of an illegal discharge, pollution and erosion.
19_ Waste handling structures, piping, pumps, reels, etc., should be inspected on a regular basis to prevent break-
downs, leaks, and spills_ A regular maintenance checklist should be kept on site_
20. Animal waste can be used in a rotation that includes vegetables and other crops for direct human consumption.
However, if animal waste is used on crops for human consumption it should only be applied preplant with no further
applications of animal waste during the crop season.
21. Highly visible markers shall be installed to mark the top and bottom elevations of the temporary storage (pumping
volume) of all animal waste lagoons. Pumping shall be managed to maintain liquid levels between the markers. A
marker will be required to mark the maximum storage volume for waste storage ponds.
22. Waste shall be tested within 60 days of utilization and soil shall be tested at least annually at crop sites where
waste is applied. Nitrogen shall be the plant food element that determines application rates. Soil zinc and copper
levels shall be monitored and alternative crop sites used when these elements approach excessive levels, pH shall
be adjusted and maintained for optimum crop production. Soil and waste analysis records shall be maintained for
5 years. Poultry dry waste application records shall be kept for three (3) years- Waste application records for all
other waste shall be kept for five (5) years.
23. Dead animals will be disposed of in a manner that meets North Carolina regulations.
Page 6 ANSON COUNTY NC

BROWN CREEK Soil Wacer Conservarion District USDA NaMral Resaurces Conservidon Service
WASTE UTILIZATION PLAN
Name of Operation:
Huntley -Vernon Farms Inc
Owner/Manages Agreement
(we) understand and will: follow and implement the specifications and the operation. and main
tenance procedures established in the approved. animai:.waste utilization: plan for the farm named
above. 1.(we) know.that any expansion to the existing desigii'capacity of the waste treatment
and storage system, or construction of new facilities will requi►eahew-certification to be sub
milted to the North -Carolina Division of Water Quality:(NCDWQ) before .new animals. are:stocked::J.
(we) also understandthat there must be no discharge of animal waste from this system to. surface
waters of North Carolina from a storm event less than the 25-year, 24-hour storm. The approved:.
plan will'be filed an -site at the farm office and.at the Brown Creek Soil & Water Conservation
District office in Wadesboro, NC. The plan will be available for review by-NCDWQ upon request.
Facility Owner
Date:
_T Huntley -Vernon Farms Inc
Facility Manager
(if different from owner)
Date:
Person Preparing Plan -R. r_)�� cli-,& Date:
R. Lin Taylor
Affiliation: USDA -Natural Resources Conservation Service
1706 Morven Road
Wadesboro, NC 28170-3142
Page 7 ANSON COUNTY NC

BROWN CREEK Soil and Wacer Grnscrvm.ioii Disfrive. Appendix 1 USDA Natural Resources Conservation Service
Keallstic
Yield —Recommended
" Soil Map Estimate Yield Nitrogen application per
Unit Symbols * CROP (RYE) Unit yield unit
Nitrogen
application Commercial
rate planned Nitrogen Used
Supplied by
Animal
Waste
per�aarew..,.x' }...;,..
-
245
575B Hybrid Bermudagrass (hay) 5 tons 187 250
245 0
246B Hybrid Bermudagrass (hay) 4 tons 150 200
196 0
196
575B Ryegrass overseeded 50 50
50 0
50
246E Ryegrass overseeded 75 100
100 0
100
Ryegrass to drilled into short (<3") bermuda sod by October 15
Waste application Requirements for 100# PAN Application
last application to bermuda by August 31
50# N may be applied to ryegrass Feb - Mar
- ryegrass should be harvested by Apr 7... any N applied to ryegrass
Apr -May must be subtracted from PAN for bermuda
NOTEIS: Yields are based on Realistic Yield Expectations for Soils of North Carolina
from N C State University,
" Soil -Crop Yield Data from NRCS Field Office Technical Guide - Section it (unless shown otherwise)
" Recommended N rates from NRCS Field Office Technical Guide - Section IV, 590 Nutrient Management
WASTE UTILIZATION PLAN ANSON COUNTY NC

BROWN CREEK Stjil Waler Coiiservdtitm District
USDA Natural Resources Conservation Service
Ell
Checklists for Animal Operations
77777M
Insect Control Checklist - Liquid Waste Systems
Source
1,11110
BMPs to Control Insects
Flush Gutters
Accumulation of Soilids
Flush system is sufficiently designed, and
operated as designed.
Remove bridging of accumulated solids at
discharge.
Lagoons and Pits
Crusted Solids
Maintain lagoon, holding pond, settling basin,
pits to minimize crusting (no more than 6-8
inches over 30% of surface).
Excessive Vegetative Growth
Decaying vegetation
Control Vegetation along perimeter banks of
lagoons and other structures to prevent
accumulation of vegetative matter.
Feeders
Feed Spillage
Design, operate and maintain feed systems
(e.g. bunkers and troughs) to minimize
accumulation of decaying wastage,
-7--1
-iro-6
-dean-up-
spillage routinely 0-d--ay
interval during the summer; 15-30 day interval
during winter),
'Feed Storage
Accumulation of feed
Reduce moisture accumulation within and
residues
around perimeter of feed storage areas by
insuring drainage away from site and/or
providing adequate containment (e.g., covered
bin for brewer's grain and similar high moisture
grain products).
Inspect for and remove or break up
accumulated solids in filter strips around feed
storage as needed.
60k. ILE
A N.VON COUNTY, NC

BROWN CREEK Suil Waler Coioservaliuie District
USDA Natural Resources Conservation Service
Odor Control Checklist - Swine
Source
BMPs to Control Insects
IMMM
Farmstead
Swine Production
Vegetative or wooded buffers, Recommended
best management practices, Good judgement
and common sense
Animal Body Surfaces
Dirty manure -covered
Dry floors
animals
Floor Surfaces
Wet manure-coverd floors
Slotted floors
Waterers located over slotted floors
Feeders at high end of solid floors
Scrape manure buildup from floors
Under roof ventilation for drying
Manure Collection pits
Urine, partial microbial
Frequent manure removal by flush, pit
decomposition
recharge, or scrape
Ventilation exhaust fans
Volitile gases, Dust
Fan maintenance, efficient air movement
Indoor Surfaces
Dust
Washdown between groups of animals
Feed additives, Feeder Covers, Feed delivery
downspout extenders
Flush tanks
Flush tank covers, Extend fill lines to near
Agitation of recycled lagoon
bottom of tanks with anti -siphon vents
liquid while tanks are fillip
Flush alleys
Agitation during wastewater
Underfloor flush with underfloor ventiliation
conve ence
Pit recharge points
Extend recharge lines to near bottom of pits
Agitation of recycled lagoon
with anti -siphon vents
liquid while pits are fillip
Lift Stations
Agitation during sump tank
Sump tank covers
filling and drawdown
Outside drain collection or
Agitation during wastewater
Box covers
unction boxes
conve ence
End of drainpipes at lagoon
Agitation during wastewater
Extend discharge point of pipes underneath
conve ence
lagoon liquid level
Lagoon Surfaces
Volitile gas emissions.
Proper lagoon liquid capacity
Biological Mixing,
Correct lagoon startup procedures
Agitation
Minimum surface area- to -volume ratio
Minimum agitation when pumping
Mechanical aeration
Proven biological additives
ANSON COUNTY, NC

hR(DPWN C:ICEUK S.,d W.rli,r C'mi-wrvrl.imi Discrici.
USDA Natural Resources Conservation Service
Odor Control Checklist - Swine continued
Irrigation sprinkler nozzles
High pressure agitation
Irrigate on dry days with little or no wind
Wind drift
Minimum operating pressure
Pump intake near lagoon liquid surface_
Pump from second -stage lagoon
Storage tank or basin
Microbial decomposition
Bottom or midlevel loading
surface
Mixing while filling
Tank covers,Basin surface mats of solids
Agitation while emptying
Proven biological additives or oxidants
Settling basin surface
Microbial decomposition
Extend drainpipe outlets underneath
Mixing while filling
liquid level
Agitation while emptying
Remove settled solids regularly
Manure, slurry or sludge
Agitation when spreading
Soil injection of slurry/sludges
spreader outlets
Volitile gas emmissions
Washdown spreader after use
Proven biological additives or oxidants
Uncovered manure, slurry
Volitile gas emissions
Soil injection of slurry/sludges __
or sludge on field surfaces
while drying
Soil incorporation within 48 hours
Spread in thin uniform layers for rapid drying
Proven biological additives or oxidants
Dead Animals
Carcass decomposition
Proper disposition of carcases (see mortality
management)
Dead animal disposal pits
Carcass decomposition
Complete covering of carcasses in pits, proper
location/construction of disposal pits
Incineration
Incom fete combustion
Secondary stack burners
Standing water around
improper drainage,
Grade and landscape so that water drains
facilities
Microbial decomposition of
away from facilities
organic matter
Manure tracked onto public
Poorly maintained access
Farm access road maintenance
roads from farm access
roads
i , 1 P!
t { s :i` t ! s,,a i '• i �,
uldl'r-'rcH w ii r (E er kj1:z,:ia, i. & .)#,.� .l#r
r .
> f,�,,.fl�.p. �� ,�, ,t;.GE•..§.. .,�.t;,,�.,.,a:, N�E,_.t,.,:i.f �.aL.�l� ,.,i y1,�...�:,'�,��?I,,=.b�".11=t.11€�`�:..t.l.:l
`31{,,.
•s:
li�l�i�
i
'����l�,�I......�i,,..l�;i
.'y:.f, 1 e 1'.rl r?�ltll
E•�..E�1:11� .,,,11
it In i-0 m,i
,i�,,�1 �3 .f� , 'i ,. .{c. fl
E 1-It t,i :l':kr. � . Y,ji f £'.!� I*Ij. iF([i1:F4F ' Y�. n rl:l 1) � -i ♦• ' ! F, JY'13'i ��j,. � [ . �.� F�.F
..--.,,.:... 1s'F. •:. t.i '�: r.• >-.. h!-' t`, . .. �.�{..i it+.>; .1� - {3rf{¢'"
�M 1
<- .i ;'3� i ,i•.I,:Y" 4 .S •I' y -' IiS(A�. Ir'.{_ '11"
I I
i :.•4 '-A> . i'"11 Si- i.,���::ti•�^rM : .}
•l . .; .�.,}, . t3jtt !Lr 5 11. � �FI.M{:' Ali
i I-0., 1 p1 -p, -0 :� id
, f t r iY. v -0� i4 �.
1
f�, jj( s r,
i ,7� �I .)� �� !I<r i
-It i?�'E ',tyt I - ! d f ,...R 1
e'1. 1.. i 'Fpq i -1
:E .i "itl "E; {
�11 �II �' ,1.
p{ ilii; ;y#,�#F'9
.!$ "i
th+ !Ft it
C ulr.. I
L i 15 , �'
i 1
,i'� �y3 k �1.-�i: lh .�t,.
1'' tt. Ily1lrl -!"is: h rE I. N .Fi'��1
I, Ilk V'_.1,
1ri- t1.' 3 S
.'� i�.
6. ;� `
,E �i�.. (; tjE��t'
:cE�J�3 �iti� ,
'i�.,1, l ri#lr
' d • r i -: 1L
I I ri'lll. -d �, �.� k I ,ill• ,,� j1Vi'.
-.1
t,! I 4 >I E.I kF 1 Et}-,:'i: 1:. •� i'.
'4 rt :15- 7
.EA i ttyy t.,.
� .n . 4iH1.t�7• !!I
II{jFt'1,�(�,f
�
',. �F 1 r_ 1 j•�I F` .�+r „1 1 tom:'. ,,' __/'
i a .i •i;ar, §I E,; l,Ij� s �911 "i I Aid;
.. ,{, ,F+'y-i �. ..;iytS. ! .�:�, IN•p ..:€d. N�! �.
I I L i „I I'. "
� 1 _
Il.'_�'- 1'7.1�.,
.f;l:I '. SIB.: I:�I'1 'it' it i:��f1
1 =.� {l{r1�(•-..�.,i `.f� ;'���. {
', it h. .. 1�..Stfr :1, -1,.
§ ..�.
.0 {r p, :l , , fy11 I
y{,,:� Y ',
�I','I+i��c .,, ,�`ir"SI�N,•j1"!I°
! f ''i. i .r: .�
I�i 1• .t':h l ' ,il .
C Yi'. �. I.. h j�'�.,''.t,A I i'I-il
�I: f�� •�..�I:����i��;��.y` }�,I:,s.
- i I,+�t,-j ill"F �wi,.3l 3�s�1,l,�t`?
�.!' {v '1• � S 4,,ff 14�',., 1,1 ,
L I
e.7, ,7 1 i3,jj',.y.
I
. : .. : R- Sti il" - " i.. 4 -} •.41 tix. 1, 'rlii YC+1 iF:t I :;,.1 I
- .H !:E , s ".i! i•--- i ,i,: €€
: 1. ! I}; :i s ,y 4j'j.-;xot,:i�`�:•' 1 i E},.3�'a��EiliPlj!n
_Y`al _EN f --I i ,L ,y{,
- r tj cr I. - -a..
!''1- hf�l- if •�-
i ;sd, rF.i:l,..l.
� �:x. ..E{�fii`�
.. � . ! . ��
'i�' 1.n f� l �•1 i1Jl .1-.. {�,i 1,�. I�f � I Y ''il Y
y 1 1, r IF r, I`rM, r t ;{H tt1 3 i ifs #
1.
�`.� �:
Mild
tl .'i 25. @:L� : 'IE! f y - :`•?4, ,S,
i'N.'41 lj,i:, i:.,:.a3f311E:Rti' rff tt ;l t�. �l
d f ^{<I. i 1'.rl� ,!�li I•i
1 sl F ..i '•�i
�E. Ily, f91 E • f, �§� 4. =1 'I,
!{?�f' �l. �r. i��j� [ ,g�`Ei
�u .
�H
�I1 -r �.
1 • ,.� i' i' :'I'E
IF' �': �,
k
`EIS .<l Fit t ,. i ! t61
'<r :
,'s�iti;!'i tY� �'�!}}o,�ct'.ii 'if#tl:
i-' "='f,3''kt !IY E�11
;i`:1 i.l. EI.i l-
y i"il i <,l '!-0r
lii"rtE � t �ii iF;: li:¢,s
' li f'i I�`�i ,��
PI't,
i 1 e
E-0�i.,#. d 1 i 4' I f I • aiif �:! 1 �_
;�., �i t, 1��.;c1 ii1 .I:f.¢'¢�.s.Ef�f`� it.i;i tc I�..
.:il _ i?•r f` 11•� N
3• a. : qE :•i.=!
illfl.f .E.
,. i' �F ?I�p�r�:-h;
1{^ � i•�., S'lf.i>,il,: ,i;,� i:.. I.e
r
,:l1 F f}= tt
�. �
11�1 _1 1 1 1 ,.h ,F � r. .�;•
1's�l. :L'='Sa ==LL II- n see' E.}. '"I:f �i ka• j 5�,�{ E:�
'3.l`'}I; E . kk p: , i .Jr - 9!i i}:,@ . rt:ls. N'i �1' ,,L IS nWl 1t `I.,.t�{� � .F�('•" y. fi,{� 1t'... Ti4'E 1 '
,t rit '. ii. jj may) ! � R } _, . �1' 11 !- 0 r �. 1,� f" '1' }, �� pry��
dl, 'i`YI . z l'" _ : ! .1, iI ., � V4�{s. rl'i: .l t: `t! 'F{j§¢�, ktl,r .$� Is,l'r, } ii 3i IH
. '::. .I �.Y. �'''1.� .�:1 �'py[�^,�� �{Ly" ., •V Fr i�3R1i- 'I �.
t.A` `, ` !:ti.!�
I.:4:%:•,' _a�'�a�L:
'yi,E-�:%i• 4KK_t.i'i�.h}�
r IT.f
,.,. � 11L! ..1 I .�J. , ,
. i!.} i . , � I"- S, �� :
q ' i�µpr" : 1y' ` E��w.FS, '� :
Fll"i .. - . �p .e :i ' 'I_ �
1 � � : 11�� + ia� � 1 A...i
{. f i
Ii't.' -0 ;l �E: t� ;;:tj�
I .�. � � � iii ` �, w'�• f . �
_ � Ft '
�F1•"1.3 �I.. 11 � 1� `
, { ;c �!�. e •
I• � ..:. �.
1 �
§• 11.-jFrCl
� ,,. ,11;;
7.{�7v I F fyaiHlj i
:i5��� 1 '�I::U`I
_ r ; _. � ' �t t 41� IA
�Y �t r' i?i€
4' _, � i�L�� 't
l:f
�!KF��
,.�91
}'�'`4H,16-1.-€.,TMj b.Yti �.i.;..3"iiitr.>4 .'A71�L �, .alFt,, � i:l..i'f . y
.43.f4t.'1I177I!,1�,ri�:'i.�- :��. �� �Ii. i'
�(b-.1a�to v ddl.�
'�.S<.:•((A.?�Ii �iiE.i.. :t4,.iMOP]
It•R. l,
{ 2Itn
�f�
.
�1jI 9
.
M!s.1t-
AN.S'ON COUNTY, NC

BROWN CREEK,Soil Water Conservation District USDA Natural Resources Conservation Service
Hundev-Vernon Farms Inc - OPERATION AND MAINTENANCE PLAN UPDATE
This structure is designed to operate as an anerobic lagoon, with waste treatment and 180 days of temporary
storage. Time required for the fluid level to fill from STOP pump elevation to START pump elevation may vary
due to site conditions, weather, flushing operations, and the amount of fresh water added to the system.
The 180 day temporary storage in this structure consists of: 1_) waste generated by confined animals; and,
2_) excess rainfall after evaporation (5" for Anson County). Additionally the structure can store the 25 year-
24 hour storm (6.3" for Anson County) above the START pump elevation_ The volume of waste generated by
3552 confined swine remains fairly constant throughout the year and from year to year. Excess
rainfall will vary from year to year_ The 25 year rainfall is not considered in the annual pumping cycle.__
this volume above the START pump elevation must be maintained and available.
The START pump or maximum normal operating fluid level is usually the outlet invert of pipe(s) from the
confinement building(s). If the outlet pipe(s) is not installed at the START pump elevation, a permanent
marker must be installed at this elevation. A STOP pump elevation must also be established to maintain
lagoon treatment depth and volume. Pumping can be started or stopped at any time between these two
elevations to land apply waste without runoff or leaching, and accommodate weather, soils, crop, equipment,
and management situations.
Land application is an accepted method of liquid waste disposal. Methods of application include solid set,
center pivot, guns, and traveling gun irrigation; honey wagon application is a more labor intensive/time
consuming method. Be careful when applying waste to prevent damage to crops.
IMPORTANT ITEMS
1. Fresh water should not be used for flushing... recycle from the anerobic lagoon.
2. The approved waste utilization plan shall be followed. This plan recommends sampling and testing of
waste prior to land application_
3. START pumping temporary storage when fluid level reaches elevation 98.2 (or before)_ STOP pumping
when fluid level reaches elevation 96.4. This temporary storage, less 25yr-24 hour storm (volume to pump)
is 38585 cubic feet (288616 gallons) every 180 days .... 77170 cubic feet (577232 gallons) per year.
4. Refer to the approved Waste Utilization Plan for important information on irrigating liquid waste --
application rates, maximum application amounts per irrigation and rest period between irrigation.
5. Keep vegetation on the embankment and areas adjacent to the lagoon mowed annually. Vegetation
should be fertilized to maintain a vigorous stand. Keep grazing livestock off all embankment areas.
6. Repair any eroded areas or areas damaged by rodents and establish in vegetation.
7. Keep all surface runoff diverted from the lagoon to stable outlets.
8. Keep a minimum 25 foot buffer area around waste utilization fields adjacent to perennial streams. Do
not apply waste in open ditches or water courses, within 100 feet of a well or within 200 feet of a residence
9. Maintain a copy of the approved Waste Management Plan on farm (or at the confined animal facility)
at all times. The Clean Water Act of 1977 prohibits the discharge of pollutants into waters of the United
States. The NC Department of Environment. Health, and Natural Resources- Division of Water Quality
is the responsible for enforcing this law.
1/16/01 ANSON COUNTY, NC

Burial three feet beneath the surface of the ground within 24 hours after
knowledge of death. Burial must be at least 300 feet from any flowing
stream or public water body_
JD Rendering at a rendering plant licensed under NC G.S_ 106-168.7
Renderer of choice for this anima! operation
Valley Proteins Inc.
ElComplete Incineration
Dead Poultry Only — placing in a disposal pit. Size and design of pit
approved by the NC Department of Agriculture.
Any method approved by the NC State Veterinarian which involves
possible salvage of part of a dead animal's value without endangering
human or animal health. (Written approval of the State Veterinarian
must be attached.

Huntley -Vernon Farms Inc
Phone Numbers
IMPORTANMY
Implement this plan if any part of the waste management system for this operation fails
or results in overapplication of waste, or discharge of waste to the waters of North Carolina!
DO NOT WAIT or PROCRASTINATE if there is a problem! Make every effort to ensure
that animal waste does not reach surface waters.. or neighboring property!!
This plan should be posted and accessible to all persons involved in the day-to-day
operation of this facilityM
Post in a Prominent Place!!!
USDA -MRCS
BROWN CREEK SWCD
Anson County NC

at
Huntley -Vernon Farms Inc
1. Stop the release of wastes Depending on the situation, this may or may not be possible. Suggested
actions are listed below.
Lagoon Overflow
Add soil material to increase elevation of embankment Call a pumping contractor
Pump waste to fields at an accceptable rate
Stop all flows into lagoon immediatley
Runoff of Field Applied Waste
Immediately stop waste application
Contain waste in a temporary diversion
Incorporate waste to prevent runoff
Leakage from Pipes, Pumps and Sprinklers
Stop recycle pump
Make sure no surface water is entering lagoon
Evaluate and eliminate reasons) for runoff
Evaluate application rate for fields where runoff occured
Close valves on leaking pipes to eliminate discharge
Stop irrigation pump Repair all leaks prior to restarting pumps
Leakage from Flush Systems, Houses, Solid Separators
Stop recycle pump Stop all flows in house, flush systems, solid separators
Stop irrigation pump Repair all leaks prior to restarting pumps
Make sure no siphon occures
Leakage from Base or Sidewall of Lagoon... often seepage as opposed to flowing leaks
Dig a small sump or ditch to safely catch seepage, install subersible pump, pump seepage back into structure
If seepage is cased by burrowing animals, trap and remove animals, compact clay soil material in holes
Have a professional evaluate the condition as soon as possible
2. Assess the extent of problem and record obvious damages.
Did waste reach any surface waters? Could spilled waste reach surface waters?
Estimate volume of waste released and duration of event Could a rain event cause waste to'reach surface waters?
Note Damage... employee injury, fish kills, property damage Are potable wells endangered (on or off property)?
Did spilled waste leave the property? Estimate how much waste reached surface waters
3. Contact appropriate agencies. See numbers posted on front of this plan.
Call the DWQ (Division of Water Quality)... Regional Office or After Hours Emergency number
Have the following information ready: Your name, facility, telephone number, details from item 2 above,
exact location of facility, direction of movement of spill, weather/wind
conditions, corrective measures taken, seriousness of situation
Call local EMS phone number if spill leaves property or enters surface waters... instruct EMS to contact Health Department
Contact local SWCD-NRCS Office for advice/technical assistance (also may want to contact Extension Service Office)
4. If none of 3 above works
Call 911 or Sherrifs Department, explain situation and ask personnel to contact the proper agencies.
S. Contact the Contractor of your choice to begin repair of problem to minimize off -site damage.
Contractor Name:
Phone:
Contact the Techical Specialist who certified the structure (NRCS, Consulting Engineer, etc.).
Technical Specialist: R.R. Lin Taylor Work Phone: [phone]
7. Implement procedures as advised by DWQ and technical assistance agencies to rectify damage, repair
system and reassess the waste management plan to ensure no future release of waste.
Post in a Prominent Place!!!
USDA-NRCS
BROWN CREEK SWCD
Anson County NC

BROWN CREEK Soil Waler Cmiservalimi Dimrict.
USDA Natural Resources Conservation Service
Waste Utilization
Form lRR-1
Irrigation Operator Facility Number 04-9
Number of Sprinklers
Tract Field bate mmlddlyy Crap Field Size (Acres) Irrigation Time Operating
Entries in these columns should correspond with Waste Utilization Plan � � • =
•
,-I N.S'ON COUNTY, NC

BROWN CREEK Soil Wals;r Cunscrvaticuit District.
USDA Natural Resources Conservation Service
Waste irrigi
Waste Utilization
Tract#
Field Size = (A)
Farm Owner
Owners Address
Owner's Phone #
Crop Type
I Field#1
Facility Number 04-9
Irrigation Operator
Irrigation Operator's
Address
Operator's Phone #
P O Box 588
Wadesboro NC 28170
[phone]
C 11 `
Reccommended PAN Loading = (B)
(tbs. Nfacre minus any commercial N applied)
(1)
(2)
(3)
(4)
(5)
(6)
(7)
(8)
(9)
(10)
(11)
Date
mm►ddlyy
Start Time
End Time
Total Minutes
(3)-(2)
Sprinklers
Operating
Flow Rate
Total
Volume
(4)X(5)X(6)
Volume Per
Acre (7)/(A)
Waste
Analysis PAN'
PAN Applied
I(8)X(9)j11000
Balance2
(B)-(10)
. -
(lb/acre)
Crop Cycle Totals
Owner's Signature Operator's Siganture
Certified Operator (print) Operator's Certification No.
' NCDA Waste Analysis or Equivalent or Estimate from NRCS TECH GUIDE Standard 633
z Enter the value received by subtracting column (10) from (B). Continue subtracting column (10) from column (11) followong each appiication event
AN.SON COUNTY, NC

BROWN CREEK Soil Water Cunservatiun District
USDA Natural Resources Conservation Service
Waste Utilization
Zecord for R
i
Spreader O erator Facility Number 04-9
Application # of Loads Per Volume Per Loa
Tract Field Date mmlddlyy Crop Field Size (Acres) Method' Field 2
Entries in these columns should correspond with Waste Utilization Plan ► -
l' Sl = soil incorporated (disked) BR = broadcast (surface applied).
2 Can be found in operator's manual for the spreader. Contact a local dealer if you do not have an owner's manual.
AMON COUNTY, NC

81to WN CREEK S,,il Walur Cu„serv.i6mt District,
USDA Natural Resources Conservation Service
Waste Utilization Recordkeeping Form SLD-2
Tract#
Field Size = (A)
Farm Owner
Owners Address
Owner's Phone #
Crop Type
Field#j
Facility Number 04-9
Spreader Operator
Spreader Operator's Address
Spreader Operator's Phone #
P 0 Box 588
Wadesboro NC 28170
[phone]
.� ,
Reccommended PAN loading = (B)
jibs. Nlacre minus any wmmercial N applied)
, i HOW
(1)
(2)
(3)
(4)
(5)
(6)
(7)
(8)
Date
mmlddlyy
# of Loads Per
Field
Volume of
Loads'
Total Volume
(2)X(3)
Volume
Per _Acre (4)/(A)
Waste Analysis
PAN
PAN Applied
I(5)X(6)jn000
Nitrogen Balance3 (B)-(7)
rise
,
s: s
�. s
r ;;I}
♦' O tl 6 s
1 _a;l
(Ibsiacre)
Crop Cycle Totalsl I I
Operator's
Owner's Signature Siganture
Certified Operator (print) Operator's Certification No.
' Can be found in operator's manual for the spreader. Contact a local dealer if you do not have an owner's manual.
2 NCDA Waste Analysis or Equivalent or Estimate from MRCS TECH GUIDE Standard 633
3 Enter the value received by subtracting column (7) from (B). Continue subtracting column (7) from column (8) followeng each application event
t
It
AN.SON COUNTY, NC

0-
Draft Date: January 13, 1999
JUSTIFICATION & DOCUMENTATION FOR MANDATORY WA DETERMINATION
Facility Number
Farm Name:
On -Site Representative:
Inspector/Reviewer's Name:
Date of site visit:
Date of most recent WUP: 1/ zS-?7
Operation is flagged for a wettable
acre determination due to failure of
Part 1l eligibility item Fl F2 F3 F4.
Aeration not required to secure WA
determination at this time based on
exemption Ell E2 E3 E4
Annual farm PAN deficit: lbs/som
Irrigation System(s) - circle: hard -hose traveler center -pivot system linear -move system
stationary sprinkler syste,rri with - ermanent i e portable pipe
ationa gun system wit permanent pipe portable pipe
PART 1. WA Determination Exemptions (Eligibility failure, Part 11, overrides Part I exemption.)
E1 Available irrigation design, including map depicting wettable acres, is completed
and signed by an l or PE.
E2 Available D, and Dz irrigation operating parameter sheets, including map
depicting wettable acres, is completed and signed by an I or PE.
E3 Available D, irrigation operating parameter sheet, including map depicting
/ wettable acres, is completed and signed by a WUP.
E4 75% rule exemption as verified in Part III. (NOTE: 75 % exemption cannot be
applied to farms that fail the eligibility checklist in Part II. Complete eligibility
checklist, Part 11- F1 F2 F3, before completing computational table in Part 111).
PART 11. 75 % Rule Eligibility Checklist and Documentation of WA Determination Requirements
WA Determination required because operation fails one of the eligibility requirements
listed below:
F1 Lack of acreage which resulted in over application of waste on spray
field(s) according to farm's last two years of irrigation records.
F2 Unclear, illegibility, or lack of inform ationtmap.
F3 Obvious field limitations (numerous ditches; failure to deduct required
buffer/setback acreage, or 25% of total acreage identified in CAWMP
includes small, irregularly shaped fields - fields less than 5 acres for
travelers or less than 2 acres for stationary sprinklers).
F4 WA determination required because CAWMP credits field(s)'s acreage in excess
of 75 % of the respective field's total acreage as noted in table in Part Ill.

Draft Date: January 13, 1999
Facility Number 61 -. Y
Part Ill. Field by field determination of 75% Exemption Rule for WA determination
TRACT
NUMBER
FIELD
NUMBERS
TYPE OF
IRRIGATION
SYSTEM
TOTAL
ACRES
CAWMP
ACRES
FIELD
%
COMMENTS
yo
3p�a
113
,�
2,
i.v
Ya
FIELD NUMBER' - hydrant, pull, zone, or point numbers may be used in place of field number depending on
CAWMP and type of irrigation system. If pulls, etc. cross more than one field, inspector/reviewer will have to
combine fields to calculate 75% field by field determination for exemption if possible; otherwise operation will
be subject to WA determination.
COMMENTS - back-up fields with acreage exceeding 75% of its total acres and having received less than
50% of its annual PAN as documented in the farm's previous two years' ('1997 & 1998) of irrigation records,
cannot serve as the sole basis for flagging. Back-up fields must be noted in the comment section.

DRAFT
JUSTIFICATION & DOCUMENTATION FOR MANDATORY WA DETERMINATION
Drafted January 12, 1999
Facility Number Operation is flagged for a wettable acre
Farm Name: determination based odihe comments
On -Site Representative: and items checked below
Inspector/Reviewer's Name:
Date of site visit:
Date of most recent WUP:
Operation not required to secure WA
determination at this time
Annual farm PAN deficit:
pounds
Irrigation System(s) - circle #: 1. hard -hose traveler; 2. center -pivot system; 3. linear -move system;
4. stationary sprinkler system w/permanent pipe; 5. stationary sprinkler system w/portable pipe;
6. stationary gun system wlpermanent pipe; 7. stationary gun system w/portable pipe
CAWMP Irrigation Components
Available irrigation design, including map depicting wettable acres, is completed and
signed by an I or PE.
Subject to WA determination because:
Available D, and D2 irrigation operating parameter sheets, including map depicting
wettable acres, is completed and signed by an I or PE.
Subject to WA determination because:
Available D, irrigation operating parameter sheet, including map depicting wettable
acres, is completed and signed by a WUP.
Subject to WA determination because:
75% Field By Field Determination for Exemption
Due to obvious field limitations (numerous ditches; 25% of total acreage in small,
irregularly shaped fields including fields less than 5 acres for travelers and less than 2
acres for stationary sprinklers/guns; failure to deduct required buffer/setback acreage,
etc.), farm is not eligible for the 750;. field by field determination exemption and is
subject to WA determination_ Comments:
Due to lack of, illegibility, or unclear information/map, farm is not eligible for the 75%
field by field determination exemption and is subject to WA determination.
Comments:
Due to lack of acreage which resulted in over application of wastewater (PAN) on spray
field(s) according to farm's last two years of irrigation records, the operation is not
eligible for the 75% field by field determination exemption and is subject to WA
determination. Comments:

C L�ts,-nz�e
ELEV. 100-00
co
n caca
- N
wooris n t Rs,o
1Q�• o /
LID
WOODS
CP
1
� N
CONTROL POI
(NUB & TACK)
�1 N SQQO.QO UMED
ELEV. 105.39
N
j ` \ 107
WOOD.S r-ISTA L W A _2 .
L
• WOODS