NC0070637_Draft Permit_20190220

y.,. ROY COOPER
Gore,no!
44 MICHAEL S. REGAN
;® r Sec,eta)),
` LINDA CULPEPPER
NORTH CAROLINA Duecto,
Environmental Quality
February 20, 2019
Mr. Greg Dellinger
Kurz Transfer Products, LP
4939 NC Hwy 150 North
Lexington, NC 27295
Subject: Draft NPDES Permit NC0070637 •
Kurz Transfer Products WWTP
Grade I Biological WPCS
Davidson County
Dear Mr.Dellinger:
The Division has reviewed your request to renew and modify the subject permit. Please review this draft
carefully to ensure a thorough understanding of the information, conditions, and requirements it contains.
The draft permit includes the following significant changes from the existing permit:
> The Effluent Limitations and Monitoring Requirements table in Section A(1) has been updated to
include the flow expansion to 0.005 MGD. The expansion did not result in changes to permit limits
or monitoring requirements for the other parameters in your permit.
> Section A. (3)has been updated regarding electronic submission of effluent data. Federal
regulations require electronic submittal of all discharge monitoring reports (DMRs).
> A list of facility treatment components for the new treatment system has been added.
• > Regulatory citations have been added to the permit.
> The permit map has been updated. Due to the short distance involved with the outfall relocation,
the latitude &longitude of the outfall will not change.
With this notification, the Division will solicit public comment on this draft permit by publishing a notice in
newspapers having circulation in the general Davidson County area,per EPA requirements. Please
provide your comments, if any,to me no later than 30 days after receiving this draft permit.
Following the 30-day public comment period, the Division will review all pertinent comments and take
appropriate action prior to issuing a final permit.If you have questions concerning the draft, please contact
me at the telephone number listed at the bottom of this page;or via e-mail [[e-mail]].
Sincerely,
Sydney Carpenter
NPDES Program
cc: NPDES File
EC
North Carolina Department of Environmental Quality I Division of Water Resources
1617 Mail Service Center I Raleigh,North Carolina 27699-1617
919-707-3712

Permit NC0070637
STATE OF NORTH CAROLINA
DEPARTMENT OF ENVIRONMENTAL QUALITY
DIVISION OF WATER RESOURCES
PERMIT
TO DISCHARGE WASTEWATER UNDER THE
NATIONAL POLLUTANT DISCHARGE ELIMINATION SYSTEM
In compliance with the provisions of North Carolina General Statute 143-215.1,
other lawful standards and regulations promulgated and adopted by the North Carolina Environmental
Management Commission,and the Federal Water Pollution Control Act, as amended,
Greg Dellinger
is hereby authorized to discharge wastewater from a facility located at
Kurz Transfer Products
4939 NC Highway 150 North
Lexington
Davidson County
to receiving waters designated as Reedy Creek in the Yadkin-Pee Dee River Basin, in accordance with effluent
limitations,monitoring requirements, and other conditions set forth in Parts I,II, III, and IV hereof.
This permit shall become effective .
This permit and authorization to discharge shall expire at midnight on May 31,2024.
Signed this day.
r
Linda Culpepper,Director
Division of Water Resources
By Authority of the Environmental Management Commission
Page 1 of 6

Permit NC0070637
SUPPLEMENT TO PERMIT COVER SHEET
All previous NPDES Permits issued to this facility,whether for operation or discharge are hereby revoked.As
of this permit issuance,any previously issued permit bearing this number is no longer effective.Therefore,the
exclusive authority to operate and discharge from this facility arises under the permit conditions,requirements,
terms,and provisions included herein.
Greg Dellinger
is hereby authorized to:
1. Continue to operate a 0.0015 MGD wastewater treatment facility that includes the following components:
• Recirculating sand filter
• 1500-gallon septic tank
• Dosing tank
• Chlorine contact tank
2. Construct and operate a new wastewater treatment facility with a treatment capacity of 0.005 MGD that
includes the following components:
• 5,000-gallon recirculating tank
• 10,000-gallon septic tank
• Advantex AX100 Pod
• TCOM Telemetry Control Panel
• Flow meter
This facility is located at Kurz Transfer Products [4939 NC Highway 150 North,Lexington] in Davidson
County.
3. Discharge from said treatment works at the location specified on the attached map into Reedy Creek,
currently classified WS-IV waters [Stream Index: 12-96-(0.7)] in sub-basin 03-07-04 [HUC: 0304010115]
of the Yadkin-Pee Dee River Basin.
Page 2 of 6

Permit NC0070637
PART I
A. (1) EFFLUENT LIMITATIONS AND MONITORING REQUIREMENTS
[15A NCAC 02B .0400 et seq.,02B .0500 et seq.]
Grade I Biological Water Pollution Control System[15A NCAC 08G.0302]
During the period beginning on the effective date of the permit and lasting until expiration,the
Permittee is authorized to discharge domestic wastewater from outfall 001. Such discharges shall be
limited and monitored' by the Permittee as specified below:
PARAMETER LIMITS MONITORING REQUIREMENTS
Monthly Daily Measurement Sample Sample
[eDMR Code] Average Maximum Frequency Type Location
Flow2 [50050] 0.0015 MGD Weekly Instantaneous Influent or
Effluent
• Flown [50050] 0.005 MGD Weekly Instantaneous Influent or
Effluent
BOD,5 day,20°C [C0310] 30.0 mg/L 45.0 mg/L 2/Month Grab Effluent
Total Suspended Solids [C0530] 30.0 mg/L 45.0 mg/L 2/Month Grab Effluent
NH3 as N [C0610] Monthly Grab Effluent
pH [00400] >6.0 and<9.0 standard units 2/Month Grab Effluent
Total Nitrogen [C0600]
(NO2+NO3+TKN) Quarterly Grab Effluent
Total Phosphorus [C0665] Quarterly Grab Effluent
Total Residual Chlorine3 [50060] 28 Ng/L 2/Week Grab Effluent
Temperature°C [00010] Weekly Grab Effluent
Footnotes:
1. The permittee shall submit discharge monitoring reports electronically using the NC DWR's eDMR
application system[see A. (3)].
2. Flow shall be limited at 0.0015 MGD until installation of the new treatment system is complete. After
installation of the new treatment system,the flow limit will increase to 0.005 MGD.
3. The Division shall consider all effluent TRC values reported below 50 µg/L to be in compliance with the
permit.However,the Permittee shall continue to record and submit all values reported by a North Carolina
certified laboratory(including field certified), even if these values fall below 50 µg/L.TRC limit and
monitoring requirements apply only if chlorine is added to disinfect.
There shall be no discharge of floating solids or foam visible in other than trace amounts.
A. (2.) NUTRIENT REOPENER FOR HIGH ROCK LAKE
[G.S. 143-215.1 (b)]
This permit may be reopened and modified to implement nutrient requirements in accordance with any
future TMDL and/or nutrient management strategy for High Rock Lake.
Page 3 of 6

Permit NC0070637
A. (3.) ELECTRONIC REPORTING OF DISCHARGE MONITORING REPORTS
[G.S. 143-215.1 (b)]
Federal regulations require electronic submittal of all discharge monitoring reports (DMRs) and
program reports. The final NPDES Electronic Reporting Rule was adopted and became effective on
December 21, 2015.
NOTE: This special condition supplements or supersedes the following sections within Part II of this
permit(Standard Conditions for NPDES Permits):
• Section B. (11.) Signatory Requirements
• Section D. (2.) Reporting
• Section D. (6.) Records Retention
• Section E. (5.) Monitoring Reports
1. Reporting [Supersedes Section D. (2.) and Section E. (5.) (a)1
The permittee shall report discharge monitoring data electronically using the NC DWR's Electronic
Discharge Monitoring Report(eDMR)internet application.
Monitoring results obtained during the previous month(s) shall be summarized for each month and
submitted electronically using eDMR. The eDMR system allows permitted facilities to enter
monitoring data and submit DMRs electronically using the internet. Until such time that the state's
eDMR application is compliant with EPA's Cross-Media Electronic Reporting Regulation
(CROMERR),permittees will be required to submit all discharge monitoring data to the state
electronically using eDMR and will be required to complete the eDMR submission by printing,
signing, and submitting one signed original and a copy of the computer printed eDMR to the following
address:
NC DEQ/Division of Water Resources/Water Quality Permitting Section
ATTENTION: Central Files
1617 Mail Service Center
Raleigh,North Carolina 27699-1617
If a permittee is unable to use the eDMR system due to a demonstrated hardship or due to the facility
being physically located in an area where less than 10 percent of the households have broadband
access, then a temporary waiver from the NPDES electronic reporting requirements may be granted
and discharge monitoring data may be submitted on paper DMR forms (MR 1, 1.1, 2, 3) or alternative
forms approved by the Director. Duplicate signed copies shall be submitted to the mailing address
above. See"How to Request a Waiver from Electronic Reporting" section below.
Regardless of the submission method,the first DMR is due on the last day of the month following the
issuance of the permit or in the case of a new facility, on the last day of the month following the
commencement of discharge.
Starting on December 21, 2020,the permittee must electronically report the following compliance
monitoring data and reports,when applicable:
Page 4 of 6

Permit NC0070637
• Sewer Overflow/Bypass Event Reports;
• Pretreatment Program Annual Reports; and
• Clean Water Act(CWA) Section 316(b)Annual Reports.
The permittee may seek an electronic reporting waiver from the Division(see"How to Request a
Waiver from Electronic Reporting" section below).
2. Electronic Submissions
In accordance with 40 CFR 122.41(1)(9),the permittee must identify the initial recipient at the time of
each electronic submission. The permittee should use the EPA's website resources to identify the
initial recipient for the electronic submission.
Initial recipient of electronic NPDES information from NPDES-regulated facilities means the entity
(EPA or the state authorized by EPA to implement the NPDES program)that is the designated entity
for receiving electronic NPDES data[see 40 CFR 127.2(b)].
EPA plans to establish a website that will also link to the appropriate electronic reporting tool for each
type of electronic submission and for each state. Instructions on how to access and use the appropriate
electronic reporting tool will be available as well. Information on EPA's NPDES Electronic Reporting
Rule is found at: http://www2.epa.gov/compliance/final-national-pollutant-discharge-elimination-
system-npdes-electronic-reporting-rule.
Electronic submissions must start by the dates listed in the"Reporting Requirements"section above.
3. How to Request a Waiver from Electronic Reporting
The permittee may seek a temporary electronic reporting waiver from the Division. To obtain an
electronic reporting waiver, a permittee must first submit an electronic reporting waiver request to the
Division. Requests for temporary electronic reporting waivers must be submitted in writing to the
Division for written approval at least sixty(60) days prior to the date the facility would be required
under this permit to begin submitting monitoring data and reports. The duration of a temporary waiver
shall not exceed 5 years and shall thereupon expire. At such time,monitoring data and reports shall be
submitted electronically to the Division unless the permittee re-applies for and is granted a new
temporary electronic reporting waiver by the Division. Approved electronic reporting waivers are not
transferrable. Only permittees with an approved reporting waiver request may submit monitoring data
and reports on paper to the Division for the period that the approved reporting waiver request is
effective.
Information on eDMR and the application for a temporary electronic reporting waiver are found on the
following web page:
https://deq.nc.gov/about/divisions/water-resources/edmr
4. Signatory Requirements [Supplements Section B. (11.) (b) and Supersedes Section B. (11.)
ll
All eDMRs submitted to the permit issuing authority shall be signed by a person described in Part II,
Section B. (11.)(a) or by a duly authorized representative of that person as described in Part II, Section
B. (11.)(b). A person, and not a position,must be delegated signatory authority for eDMR reporting
purposes.
Page 5 of 6

Permit NC0070637
For eDMR submissions,the person signing and submitting the DMR must obtain an eDMR user
account and login credentials to access the eDMR system. For more information on North Carolina's
eDMR system,registering for eDMR and obtaining an eDMR user account,please visit the following
web page:
http://deq.nc.gov/about/divisions/water-resources/edmr
Certification. Any person submitting an electronic DMR using the state's eDMR system shall make
the following certification [40 CFR 122.22]. NO OTHER STATEMENTS OF CERTIFICATION
WILL BE ACCEPTED:
"I certify,under penalty of law, that this document and all attachments were prepared under my
direction or supervision in accordance with a system designed to assure that qualified personnel
properly gather and evaluate the information submitted. Based on my inquiry of the person or persons
who manage the system, or those persons directly responsible for gathering the information,the
information submitted is,to the best of my knowledge and belief, true, accurate, and complete. I am
aware that there are significant penalties for submitting false information,including the possibility of
fines and imprisonment for knowing violations."
5. Records Retention [Supplements Section D. (6.)1
The permittee shall retain records of all Discharge Monitoring Reports, including eDMR submissions.
These records or copies shall be maintained for a period of at least 3 years from the date of the report.
This period may be extended by request of the Director at any time [40 CFR 122.41].
Page 6 of 6

J4 ` tT-��• i i� t�( -`eft i \I,. �., �:/ rf• -il.}`•. n•. • f� , t�� -�J
;, ,.r �l
, ,,..,,,,, . ...\... .„,,,,,, , \,, ,
,, „,‘,,, ,,. ,
,,
1
1-1 , 1.
�,� ` ��� �[ � � ill ; •-)�ti, ��. � ;� � �
{'1
t ` r J 1 ,r
• ••-- � fi'Goodtiope cis y >s__
t 15� .t U 1, 1 4 I,.
'
/=..jam` "}FO• (j/, l t' i t "\+�
....7—\)' ,,, / •,," , \ ,-,, si,,,\.,,, ) 1 - f .," •/ ,'" /.--F-7-:,:1 ,,,,-, '
' 1'\ mot ' 7i _\\ ::,� � � - ?l tr
. k --_ 2 )-, - ,f\ 1, I
1
t I, Creek '_..
a
AI i • i
a
Reedy •
t1 l _ o/ I4411 • /ail\ ,'• ,IA66 _ , 7 ••— ^-
11*4
r ' ).
,. ;„ .,...7-- . , ‘,,L'• , — • ./. 'i',). r.,„,,..s„ ri ,;• ir.s.. . i )...„ ,,, 112 ) r 6;5;.-...._ ;7,__,..i,
cc
'
/ 1 _ \ ,,f c -,c 1. \ C . ._)1-- / .��
✓ � • •r � � — -'
• Ifs f .., �,• .!__. ti ) : rd 'c.
,4
_. , -,_. •,' ., __ ,,,. .,•..-7-1,7.7f; \.--, ' *-7.;\*17(- -___P.: •• ..__Y-, __;,,/,-;/,/,,j- •---:--;•-7-;_-. s._•`--•,` •
•
� \�_-,, ' ` f•( i--- _ ...E%, ' J .\\- ti.�.,,a-- , ..
Kurz Transfer Products WWTP Facility •
Location
USGS Quad: Welcome Lat.: 35°54'47"
Receiving Stream: Reedy Creek Long.: 80°19'50" - -
Stream Class: WS-IV Sub-basin: 03-07-04 NPDES Permit NC0070637
Basin: Yadkin- Pee Dee HUC: 0304010115 North Davidson County