WQ0038735_Final Permit_20161110

Water
Resources
ENVIRONMENTA3, QUALITY
November 10, 2016
KENDRA D. PARRISH, PE — DIRECTOR OF ENGINEERING
TOWN OF HOLLY SPRINGS
POST OFFICE Box 8
HOLLY SPRINGS, NORTH CAROLINA 27540
Dear Ms. Parrish:
PAT MCCRORY
Governor
DONALD R. VAN DER VAART
.Secrefory
S. JAY ZIMMERMAN
Director
Subject: Permit No. WQ0038735
Twelve Oaks — Phase 6 Section 2
Reclaimed Water Distribution Line
Wake County
In accordance with your permit application request received September 13, 2016, and subsequent
additional information received October 24, 2016, we are forwarding herewith Permit No. WQ0038735
dated November 10, 2016, to the Town of Holly Springs for the construction and operation of the subject
reclaimed water distribution lines.
If any parts, requirements or limitations contained in this permit are unacceptable, the Permittee
has the right to request an adjudicatory hearing upon written request within 30 days following receipt of
this permit. This request shall be in the form of a written petition, conforming to Chapter 150B of the North
Carolina General Statutes, and filed with the Office of Administrative Hearings at 6714 Mail Service
Center, Raleigh, NC 27699-6714. Unless such demands are made, this permit shall be final and binding.
One set of approved plans and specifications is being forwarded to you. If you need additional
information concerning this permit, please contact Ashley Kabat at [phone] or
ashely.kabat( lacdenngov.
Sincerely,
ZZ76�-D-
�S-
Jay Zimmerman, P. G., Dire for
Division of Water Resources
cc: Wake County Health Department (Electronic Copy)
Raleigh Regional Office, Water Quality Regional Operations Section (Electronic Copy)
Thomas J. Spaulding, PE — Spaulding & Norris, PA (Electronic Copy)
Digital Permit Archive (Electronic Copy)
Central Files
State of North Carolina I Environmental Quality I Water Resources I Water Quality Permitting I Non -Discharge Permitting
16171%Uil Service Center I Raleigh, North Carolina 27699-1617
919 807 6464

TH2S PACE 13 LANK

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENTAL QUALITY
RALEIGH
RECLAIMED WATER DISTRIBUTION LINE PERMIT
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North Carolina as
amended, and other applicable Laws, Rules and Regulations
PERMISSION IS HEREBY GRANTED TO
Town of Holly Springs
Wake County
FOR THE
construction and operation of a reclaimed water distribution system extension consisting of. 226 linear feet
(LF) of 4 -inch PVC reclaimed water line and 150 LF of 6 -inch PVC reclaimed water line, and all associated
piping, valves, controls and appurtenances
to serve Twelve Oaks — Phase 6 Section 2, with no discharge of wastes to surface waters, pursuant to the
application received September 13, 2016, and subsequent additional information received by the Division
of Water Resources, and in conformity with the project plans, specifications, and other supporting data
subsequently filed and approved by the Department of Environmental Quality and considered a part of this
permit.
I. SCHEDULES
Upon completion of construction and prior to operation of the new reclaimed water distribution
facilities, a certification (attached) shall be submitted from a licensed North Carolina Professional
Engineer certifying that the permitted facility has been installed in accordance with this permit,
Division approved plans and specifications, and other supporting documentation, including the location
of all monitoring wells as applicable. If this project is to be completed in phases and partially certified,
the Permittee _shall retain the responsibility to track further construction Q12roved under the same
permit, and shall provide a final certificate of completion once the entire project has been completed.
Mail the Certification to the Division. of Water Resources, Water Quality Permitting Section, 1617 Mail
Service Center, Raleigh, NC 27699-1617. [15A NCAC 02T .0116]
2. Operation of this reclaimed water distribution line shall be contingent upon proper construction and
operation of approved reclaimed water distribution lines immediately upstream and downstream of the
line approved herein. Future upstream and downstream reclaimed water distribution lines
specifications shall include quality assurance testing procedures, and those procedures shall be used
prior to operation of this reclaimed water distribution line. [G. S. 143-215.1 ]
WQ0038735 Version 1.0 Shell Version 151201 Page 1 of 6

H. PERFORMANCE STANDARDS
1. The subject reclaimed water facilities shall be effectively maintained and operated at all times so there
is no discharge to surface waters, nor any contravention of groundwater or surface water standards. In
the event the facilities fail to perform satisfactorily, including the creation of nuisance conditions due
to improper operation and maintenance, or failure of the utilization areas to adequately assimilate the
reclaimed water, the Permittee shall take immediate corrective actions including Division required
actions, such as the construction of additional or replacement reclaimed water distribution facilities.
[G.S. 143-215.1, 143-213.3(a)]
2. This permit shall not relieve the Permittee of their responsibility for damages to groundwater or surface
water resulting from the operation of this reclaimed water distribution line. [ 15A NCAC 02B .0200,
02L .0100]
3. Construction of the reclaimed water distribution line permitted herein shall be scheduled as not to
interrupt service of existing utilities, or result in an overflow or bypass discharge of reclaimed water to
surface waters of the State. [ 15A NCAC 02T .0108(b)(1)]
4. The following shall be requirements for the reclaimed water distribution facilities:
a. All reclaimed water valves, storage facilities and outlets shall be tagged or labeled to warn the
public or employees that reclaimed water is not intended for drinking. Where appropriate, such
warning shall inform the public or employees to avoid contact with reclaimed water.
b. All reclaimed water piping, valves, outlets and other appurtenances shall be color -coded, taped or
otherwise marked to identify the source of the water as being reclaimed water.
i. All reclaimed water piping and appurtenances shall be either colored purple (i.e., Panton 522)
and embossed or integrally stamped or marked "CAUTION: RECLAIMED WATER — DO
NOT DRINK" or be installed with a purple (i.e., Pantone 522) identification tape or
polyethylene vinyl wrap. The warning shall be stamped on opposite sides of the pipe and
repeated every three feet or less.
ii. Identification tape shall be at least three inches wide and have white or black lettering on purple
(i.e., Pantone 522) field stating "CAUTION: RECLAIMED WATER — DO NOT DRINK."
Identification tape shall be installed on reclaimed water pipelines in a visible manner, fastened
at least every 10 feet to each pipe length and run continuously the entire length of the pipe.
iii. Existing underground distribution systems retrofitted for the purpose of distributing reclaimed
water shall be taped or otherwise identified as noted above. This identification need not extend
the entire length of the distribution system, but shall be incorporated within 10 feet of crossing
any potable water supply line or sanitary sewer line.
c. All reclaimed water valves and outlets shall be of a type, or secured in a manner, that permits
operation by authorized personnel only.
d. Hose bibs shall be located in locked, below grade vaults that shall be labeled as being of non -
potable quality. As an alternative to the use of locked vaults with standard hose bib services, other
locking mechanisms such as hose bibs which can only be operated by a tool may be placed above
ground and labeled as non -potable water.
[15A NCAC 02U .04031
5. No direct cross -connections shall be allowed between reclaimed water and potable water systems,
unless such connection has been approved by the Department pursuant to 15A NCAC 18C .0406. [15A
NCAC 02U.0403(f)]
6. Reclaimed water distribution lines shall be located at least 10 feet horizontally from and 18 inches
below any water line where practicable. Where these separation distances cannot be met, the piping
and integrity testing procedures shall meet water main standards in accordance with 15A NCAC 18C.
[I5ANCAC 02U .0403(h)]
WQ0038735 Version 1.0 Shell Version 151201 Page 2 of 6

M.
7. Reclaimed water distribution lines shall not be less than 100 feet from a well unless the piping and
integrity testing procedures meet water main standards in accordance with 15A NCAC 18C, but in no
case shall they be less than 25 feet from a private well or 50 feet from a public well. [15A NCAC 02U
.0403(i)]
8. Reclaimed water distribution lines shall be located at least two feet horizontally from and 18 inches
above any sewer line where practicable. Where these separation distances cannot be met, the piping
and integrity testing procedures shall meet water main standards in accordance with 15A NCAC 18C.
[15A NCAC 02U.04030)]
9. The facilities permitted herein shall be constructed according to the following setbacks:
a. The separation distances for reclaimed water distribution lines permitted herein shall be as follows
(distances as specified) 1:
i. Any potable water line (horizontal): loft
ii. Any potable water line (vertical — reclaimed below potable water): 18 in
iii. Any well with exception of monitoring wells: 100 ft
iv. Any sewer line (horizontal): 2 ft
v. Any sewer line (vertical — reclaimed over sewer): 18 in
t In any instance where the above separation distances cannot be met, the piping and integrity testing
procedures shall meet water main standards in accordance with 15A NCAC 18C, but in no case shall
reclaimed distribution lines be less than 25 feet from a private well or 50 feet from a public well.
[15A NCAC 02U .0701]
OPERATION AND MAINTENANCE REQUIREMENTS
Only reclaimed water generated from Town of Holly Springs (Permit No. WQ0032289) shall be
distributed in the lines permitted herein prior to being utilized. [15A NCAC 02T .0108(b)(1)]
2. The reclaimed water distribution lines permitted herein shall be properly maintained and operated at all
times. To ensure proper operation and maintenance, the Permittee shall perform the following:
a. A map of the reclaimed water distribution line shall be developed. If part of a broader reclaimed
water distribution system, this line shall be added to the regional map, and said map shall be actively
maintained.
b. An operation and maintenance plan shall be developed and implemented.
c. A general observation of the entire reclaimed distribution system shall be conducted at least once
per year.
d. Inspection and maintenance records shall be maintained for a period of at least three years.
e. Bypasses shall be reported to the Raleigh Regional Office in accordance with 15A NCAC 02B
.0506(a).
[15ANCAC 02U.08011
WQ0038735 Version 1.0 Shell Version 151201 Page 3 of 6

IV. MONITORING AND REPORTING RE UIRMENTS
1. Any Division required monitoring (including groundwater, plant tissue, soil and surface water analyses)
necessary to ensure groundwater and surface water protection shall be established, and an acceptable
sampling reporting schedule shall be followed. [15A NCAC 02T .0108(c)]
2. Noncompliance Notification:
The Permittee shall report by telephone to the Raleigh Regional Office, telephone number (919) 791-
4200, as soon as possible, but in no case more than 24 hours, or on the next working day following the
occurrence or first knowledge of the occurrence of any of the following:
a. Any failure resulting in a discharge of reclaimed water directly to surface waters or any unpermitted
release of reclaimed water to land surface greater than or equal to 5,000 gallons. Unpermitted
releases less than 5,000 gallons to land surface shall be documented by the Permittee in accordance
with Condition IV. 8.e. but do not require Regional Office notification.
b. Any failure, due to known or unknown reasons, that renders the reclaimed water distribution line(s)
incapable of adequately transporting the reclaimed water (e.g., mechanical or electrical failures,
line blockages or breaks, etc.);
Any emergency requiring immediate reporting (e.g., discharges to surface waters, imminent failure of
a storage structure, etc.) outside normal business hours shall be reported to the Division's Emergency
Response personnel at telephone number [phone], (800) 8580368, or [phone]. Persons
reporting such occurrences by telephone shall also file a written report in letter form within five days
following first knowledge of the occurrence. This report shall outline the actions taken or proposed to
betaken to ensure the problem does not recur. [15A NCAC 02T .0108(b)(1)]
V. INSPECTIONS
1. The Permittee shall provide adequate inspection and maintenance to ensure proper operation of the
distribution line(s). [15A NCAC 02T .0108(b)]
2. The Permittee or their designee shall inspect the distribution line(s) to prevent malfunction, facility
deterioration and operator errors resulting in discharges, which may cause the release of wastes to the
environment, a threat to human health or a public nuisance. The Permittee shall maintain an inspection
log that includes, at a minimum, the date and time of inspection, observations made, and any
maintenance, repairs, or corrective actions taken. The Permittee shall maintain this inspection log for
a period of five years from the date of the inspection, and this log shall be made available to the Division
upon request. [15A NCAC 02T .0108(b)]
3. Any duly authorized Division representative may, upon presentation of credentials, enter and inspect
any property, premises or place on or related to the distribution line(s) permitted herein at any
reasonable time for the purpose of determining compliance with this permit; may inspect or copy any
records required to be maintained under the terms and conditions of this permit, and may collect
groundwater, surface water or leachate samples. [G. S. 143-215.1]
VI. GENERAL CONDITIONS
1. Failure to comply with the conditions and limitations contained herein may subject the Permittee to an
enforcement action by the Division in accordance with North Carolina General Statutes 143-215.6A to
143-215.6C. [G.S. 143-215.6A to 143-215.6C]
2. This permit shall become voidable if the permitted facilities are not constructed in accordance with the
conditions of this permit, the Division approved plans and specifications, and other supporting
documentation. [ 15A NCAC 02T .0110]
WQ0038735 Version 1.0 Shell Version 151201 Page 4 of 6

3. This permit is effective only with respect to the nature and volume of wastes described in the permit
application, Division approved plans and specifications, and other supporting documentation. No
variances to applicable rules governing the construction or operation of the permitted facilities are
granted, unless specifically requested and approved in this permit pursuant to 15A NCAC 02T .0105(n).
[G. S. 142-215,1]
4. The issuance of this permit does not exempt the Permittee from complying with any and all statutes,
rules, regulations, or ordinances, which may be imposed by other jurisdictional government agencies
(e.g., local, state, and federal). Of particular concern to the Division are applicable river buffer rules in
15A NCAC 02B .0200; erosion and sedimentation control requirements in 15A NCAC Chapter 4 and
under the Division's General Permit NCG010000; any requirements pertaining to wetlands under 15A
NCAC 02B .0200 and 02H .0500; National Pollutant Discharge Elimination System (NPDES)
requirements under 15A NCAC 02H .0 100, and documentation of compliance with Article 21 Part 6
of Chapter 143 of the General Statutes. [I 5A NCAC 02T .0105(c)(6)]
In the event the permitted facilities change ownership or the Permittee changes their name, a written
permit modification request shall be submitted to the Division. This request shall be made on official
Division forms, and shall include appropriate property ownership documentation and other supporting
documentation as necessary. The Permittee of record shall remain fully responsible for maintaining
and operating the facilities permitted herein until a permit is issued to the new owner. [15A NCAC
02T.01041
6. The Permittee shall retain a set of Division approved plans and specifications for the life of the facilities
permitted herein. [15A NCAC 02T .0108(b)(1)]
Permit issued this the 101 day of November 2016
NORTH CAROLINA ENVIRONMENTAL MANAGEMENT COMMISSION
7S. Jay Zimmerman, P.G., Director
Division of Water Resources
By Authority of the Environmental Management Commission
Permit Number WQ0038735
WQ0038735 Version 1.0 Shell Version 151201 Page 5 of 6

Permit No. WQ0038735
Town of Holly Springs
Twelve Oaks — Phase 6 Section 2
ENGINEERING CERTIFICATION
❑ Partial ❑ Final
Reclaimed Water Distribution Line
November 10, 2016
Wake County
In accordance with 15A NCAC 02T .0116, I, , as
a duly registered Professional Engineer in the State of North Carolina, having the Permittee's authorization
to ❑ periodically ❑ weekly ❑ fully observe the construction of the permitted facility, hereby state to the
best of my abilities that due care and diligence was used in the observation of the construction, such that
the facility was built within substantial compliance and intent of this permit, the Division approved plans
and specifications, and other supporting documentation.
❑ Any variation to this permit, the Division approved plans and specifications, and other supporting
documentation has been documented in the attached as -built drawings, and shall serve as the
Permittee's minor modification request to amend the permit accordingly.
Provide a brief narrative description of any variations:
Professional Engineer's Name
Engineering Firm
Mailing Address
City State Zip
Telephone E-mail NC PE Seal, Signature &Date
THE COMPLETED ENGINEERING CERTIFICATION, INCLUDING ALL SUPPORTING
INFORMATION AND MATERIALS, SHALL BE SENT TO THE FOLLOWING ADDRESS:
NORTH CAROLINA DEPARTMENT OF ENVIRONMENTAL QUALITY
DIVISION OF WATER RESOURCES
WATER QUALITY PERMITTING SECTION
NON -DISCHARGE PERMITTING UNIT
By U.S. Postal Service:
1617 MAIL SERVICE CENTER
By Courier/Special,DeIivery:
512 N. SALISBURY STREET
RALEIGH, NORTH CAROLINA 27699-1617 RALEIGH, NORTH CAROLINA 27604
WQ0038735 Version 1.0 Shell Version 151201
Page 6 of 6