WQ0031876_Final Permit_20070720

r o~r w A TAR
7
4 �
July 20, 2007
BARRY PARKS
ASSISTANT DIRECTOR OF PUBLIC SERVICI SlWATFR R.ESC)i. ikas
CITY OF WILSON
P.O. Box 10
Wilson, NC 27894-0010
Dear Mr. Parks:
Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Coleen H. Sullins Director
Division of Water Quality
Subject; Permit No. WQ0031876
Reclaimed Water By -Pass .Line
Reclaimed Water Line Extension
Wilson County
In accordance with your permit application received June 18, 2007, we are forwarding herewith
Permit Number WQ0031876, dated July 20, 2007, to the City of Wilson for the construction and
operation of the subject reclaimed water utilization extension.
This permit shall be effective from the date of issuance until rescinded, and shall be subject to the
conditions and limitations as specified therein. Failure to establish an adequate system for collecting and
maintaining the required operational information will result in future compliance problems,
If any parts, requirements, or Iimitations contained in this permit are unacceptable, you have the
right to request an adjudicatory hearing upon written request within thirty (30) days following receipt of
this permit. This request must be in the form of a written petition, conforming to Chapter 150B of the
North Carolina General Statutes, and filed with the Office of Administrative Hearings, 6714 Mail Service
Center, Raleigh, NC 27699-6714. Unless such demands are made this permit shall be final and binding.
One set of approved plans and specifications is being forwarded to you. If you need additional
information concerning this matter, please contact Matthew Fleahman at [phone].
Sincerely
-4&
,Coleen H. Sullins
cc: Wilson County Health Department
Raleigh Regional Office, Aquifer Protection Section
W. Landon Younce, P.E. — Green .Engineering, PLLC
APS Central Files
LAU Files
No e hCarolina
Iatura!!y
Aquifer Protection Section 1636 Mail Service Center Raleigh, NC 27699-1636 Phone [phone] Customer Service
Internet: http:iMo.enr.state.nc.us 2728 Capital Boulevard Raleigh, NC 27604 Fax [phone]
Fax [phone]
An Equal Opportunity/Affirmative Action Employer— M Recycled110% Post Consumer Paper

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT DF ENVIRONMENT AND NATURAL RESOURCES
RALEIGH
RECLAIMED WATER UTILIZATION PERMIT
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North Carolina as
amended, and other applicable Laws, Rules, and Regulations
PERMISSION IS HEREBY GRANTED TO
City of Wilson
Wilson County
FOR THE
construction and operation of a reclaimed water utilization system extension consisting of approximately
285 linear -feet of 24-inch reclaimed water by-pass line between post -aeration and reclaimed water
holding pond, and all associated piping, valves and appurtenances to serve the City, of Wilson with no
discharge of wastes to the surface waters, pursuant to the application received June 18, 2007 and
subsequent additional information received by the Division, and in conformity with the project plan,
specifications, and other supporting data subsequently filed and approved by the Department of
Environment and Natural Resources and considered a part of this permit.
This permit shall be effective from the date of issuance until rescinded and shall be subject to the
following specified conditions and limitations:
�i�:73��►i1•1!\►[�1�.`111►\►117\:� 17.y
Upon completion of construction and prior to operation of this permitted operation, a certification
must be received from a professional engineer certifying that the permitted operation has been
installed in accordance with this permit, the approved plans and specifications, and other supporting
materials. If this project is to be completed in phases and partially certified, you shall retain the
responsibility to track further construction approved under the same permit, and shall provide a final
certificate of completion once the entire project has been completed.. Mail the Certification to the
Aquifer Protection Section, 1636 Mail ,Service Center, Raleigh, NC 27699-1636,
2. The reclaimed water utilization facilities shall be effectively maintained and operated at all times so
that there is no discharge to the surface waters, nor any contamination of ground waters, which will
render them unsatisfactory for normal use. In the event that the facilities fail to perform satisfactorily,
including the creation of nuisance conditions or failure of the irrigation area to adequately assimilate
the wastewater, the Permittee shall take immediate corrective actions including those actions that may
be required by the Division of Water Quality, such as the construction of additional or replacement
reclaimed distribution facilities.
This permit shall become revocable unless the reclaimed distribution facilities are constructed in
accordance with the conditions of this permit; 15A NCAC 2H .0200; the Division of Water Quality's
Gravity Sewer Minimum Design Criteria adopted February 12, 1996 as applicable; the Division's
Minimum Design Criteria for the Fast -Track Permitting of Pump Stations and Force Mains adopted
June 1, 2000 as applicable; and other supporting materials unless specifically mentioned herein.

4. This permit is effective only with respect to the nature and volume of wastes described in the
application and other supporting data.
S. The reclaimed distribution facilities shall be properly maintained and operated at all times:
a. The reclaimed system shall be effectively maintained and operated at all times to prevent
discharge to land or surface waters, and any contravention of the groundwater standards in 15A
NCAC 2L .0200 or the surface water standards in 15A NCAC 2B .0200.
b. A map of the reclaimed system shall be developed and shall be actively maintained.
c. An operation and maintenance plan shall be developed and implemented.
d. A general observation of the entire reclaimed distribution system shall be conducted at least once
per year.
e. Inspection and maintenance records shall be maintained for a period of at least three years.
f. Bypasses shall be reported to the appropriate Division regional office in accordance with 15A
NCAC 2B .0506(a).
6. The reclaimed water distributed by this system shall be treated in the City of Wilson— I:Iosniny Creek
WWMT, (NC0023906) prior to being irrigated.
7. This permit is not transferable. In the event there is a desire for the facilities to change ownership, or
there is a name change of the Permittee, a formal permit request must be submitted to the Division of
Water Quality accompanied by documentation from the parties involved and other supporting
materials as may be appropriate. The approval of this request will be considered on its merits and
may or may not be approved.
8. Construction of the reclaimed water distribution system shall be scheduled so as not to interrupt
service by the neither existing utilities nor result in an overflow or bypass discharge of reclaimed
water to the surface waters of the State.
9. A copy of the approved plans and specifications shall be maintained on file by the Permittee for the
life of the reclaimed distribution facilities.
10. Failure to abide by the conditions and limitations contained in this permit; 15A NCAC 2H .0200; the
Division's Gravity Sewer Design Criteria adopted February 12, 1996 as applicable; the Division's
Minimum Design Criteria for the Fast -Track Permitting of Pump Station and Force Mains adopted
June 1, 2000 as applicable; and other supporting materials may subject the Permittee to an
enforcement action by the Division, in accordance with North Carolina General Statutes § 143-215.6A
through §143-215.6E
11. The issuance of this permit does not exempt the Pcrmittee from complying with any and all statutes,
rules, regulations, or ordinances that may be imposed by other government agencies (i.e., local, state,
and federal) having jurisdiction, including but not limited to applicable river buffer rules in 15A
NCAC 2B .0200, soil erosion and sedimentation control requirements in 15A NCAC Chapter 4 and
under the Division's General Permit NCG010000, and any requirements pertaining to wetlands under
15A NCAC 213 .0200 and 15A NCAC 211.0500.
12. In the event that the facilities fail to perform satisfactorily, including the creation of nuisance
conditions, the Permittee shall take immediate corrective action, including those that may be required
by this Division, such as the construction of additional or replacement reclaimed distribution
facilities.
2

13. The Permittee shall provide the following items for the reclaimed water system:
a. An air relief valve located at all high points along the force main.
b. Three feet of cover (minimum) over the force main or the use of ferrous material where three feet cannot
be maintained.
c. Adherence with the following minimum separations:
(i) Sewer systems (vertical — reclaimed over sewer) 18 inches or (horizontal) 2 feet
(ii) Water mains (vertical -water over sewer) 18 inches or (horizontal) 10 feet
(iii) Reclaimed water distribution lines shall not be less than. 100 feet from a well unless the
piping and integrity testing procedures meet water main standards in accordance with 15A
NCACI8C, but no case shall they be less than 25 feet from a private well or 50 feet from a
public well.
14. The issuance of this permit shall not relieve the Permittee of the responsibility for damages to surface
or groundwaters resulting from the operation of this facility.
15. Any monitoring (including groundwater, surface water, soil or plant tissue analyses) deemed
necessary by the Division to insure surface and ground water protection will be established and an
acceptable sampling reporting schedule shall be followed.
16. This permit shall become voidable unless the facilities are constructed in accordance with the
conditions of this permit, the approved plans and specifications, and other supporting data.
17. Failure to abide by the conditions and limitations contained in this permit may subject the Permittee
to an enforcement action by the Division in accordance with North Carolina General Statute 143-
215.6A to 143-215.6C.
18. Adequate inspection and maintenance shall be provided by the Permittee to insure proper operation of
the subject facilities.
19. Any duly authorized officer, employee, or representative of the Division may, upon presentation of
credentials, enter and inspect any property, premises or place on or related to the disposal site or
facility at any reasonable time for the purpose of determining compliance with this permit; may
inspect or copy any records that must be maintained under the terms and conditions of this permit,
and may obtain samples of groundwater, surface water, or leachate.
20. The Permittee or his designee shall operate the reclaimed distribution system to prevent malfunctions
and deterioration, operator errors and discharges which may cause or lead to the release of reclaimed
water to the environment, a threat to human health, or a nuisance, The Permittee shall keep an
inspection log or summary including at least the date and time of inspection, observations made, and
any maintenance, repairs, or corrective actions taken by the Permittee. This log of inspections shall
be maintained by the Permittee for a period of three years from the date of the inspection and shall be
made available upon request to the Division or other permitting authority.
21. The following shall be requirements for the reclaimed water distribution, storage, and utilization
facilities:
a. All reclaimed water valves, storage facilities, and outlets shall be tagged or labeled to warn the
public or employees that the water is not intended for drinking. Where appropriate, such warning
shall inform the public or employees to avoid contact with the water.
b. All reclaimed water piping, valves, outlets, and other appurtenances shall be color -coded, taped,
or otherwise marked to identify the source of the water as being reclaimed water.

i. All reclaimed water piping and appurtenances shall be either colored purple (i.e., Pantone
522) and embossed or integrally stamped or marked "CAUTION: RECLAIMED WATER —
DO NOT DRINK" or be installed with a purple (i.e., Pantone 522) identification tape or
polyethylene vinyl wrap. The warning shall be stamped on opposite sides of the pipe and
repeated every three feet or less.
ii. Identification tape shall be at least three inches wide and have white or black lettering on
purple (i.e., Pantone 522) field stating "CAUTION: RECLAIMED WATER -- DO NOT
DRINK." Identification tape shall be installed on top of reclaimed water pipelines, fastened
at least every 10 feet to each pipe length and run continuously the entire length of the pipe.
c. All reclaimed water valves and outlets shall be of a type, or secured in a manner, that permits
operation by authorized personnel only.
d. Aboveground hose bibs (i.e., spigots or other hand -operated connections) shall not be present.
Hose bibs shall be located in locked below -grade vaults that shall be clearly labeled as being of
non -potable quality. As an alternative to the use of locked below -grade vaults with standard hose
bibs- services, hose bibs, which can only be operated by a special tool or connected to a special
hose connection may be placed in non -lockable underground services boxes clearly labeled as
non -potable water.
22. Noncompliance Notification:
The Permittee shall verbally report to a water quality staff member at the Raleigh Regional Office,
telephone number [phone], as soon as possible, but in no case more than 24 hours or on the
next working day following the occurrence or first knowledge of the occurrence of either of the
following:
a. Any process unit failure, due to known or unknown reasons, that render the facility incapable of
adequate wastewater transport such as mechanical or electrical failures of pumps, line blockage or
breakage, etc.
b. Any failure of a distribution line resulting in a by-pass directly to receiving waters.
Voice mail messages or faxed information is permissible but this shall not be considered as the initial
verbal report. Overflows and spills occurring outside normal business hours may also be reported to
the Division of Emergency Management at telephone number [phone] or [phone].
Persons reporting any of the above occurrences shall file a spill report by completing Part I of Form
CS-SSO (or the most current Division approved form), within five days following first knowledge of
the occurrence. This report shall outline the actions taken or proposed to ensure that the problem
does not recur.
Permit issued this the 20t` day of July, 2007
NORTH C OLINA E
TMONMENTAL MANAGEMENT COMMISSION
Coleen H. Sullins, Director
Division of Water Quality
By Authority of the Environmental Management Commission
Permit Number WQ0031.876
4

Permit No. WQ0031876
July 20, 2007
ENGINEER'S CERTIFICATION
Partial Final
1, , as a duly registered Professional Engineer in the State
of North Carolina, having been authorized to observe (periodically, weekly, full time) the construction of
the project,
Project Name
Location and County
for the Permittee hereby state that, to the best of my abilities, due care and diligence was used in the
observation of the construction such that the construction was observed to be built within substantial
compliance and intent of this permit, the approved plans and specifications, and other supporting
materials.
Signature
Date
Registration No.