WQ0030125_Final Permit_20060313

Michael F. Easley, Govemor
William G. Ross Jr., Secretary
NUrth Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E, Director
Division of Water Quality
April I3, 2006
Mr. Thomas Gibson
Valley Proteins, Inc.
Post Office Box 3588
Winchester, Va. 22604-2586
Subject: Pump & Haul Permit No. WQ0030125
Carolina By -Products -Rose Hill
Duplin County
Dear Mr. Gibson:
In accordance with your application received April 13, 2006, we are forwarding herewith Permit
No. WQ0030125, dated April 13, 2006 to Carolina By -Products for the temporary operation of pump
and haul activities transporting up to 20,000 gpd of treated domestic & industrial wastewater from the
Carolina By -Products spray irrigation lagoon, Permit No. WQ0000485, to the influent pumping .station of
the Town of Rose Hill WWTP, Permit No. NC0056863.
This permit shall be effective from April 13, 2006 until October 13, 2006 and shall be subject to
the conditions and limitations as specified therein. Please pay particular attention to the monitoring
requirements in this permit. Failure to establish an adequate system for collecting and maintaining the
required operational information will constitute noncompliance with the permit. Also, please note
Condition No. 8 in the permit which states that the permit will not be renewed and that the pump and
haul activity will cease upon the expiration date.
If any parts, requirements, or limitations contained in this permit are unacceptable to you, you
have the right to request an adjudicatory hearing upon written request within 30 days following receipt of
this permit. This request must be in the form of a written petition, conforming to Chapter 150B of North
Carolina General Statutes, and filed with the Office of Administrative Hearings, P.O. Drawer 27447,
Raleigh, NC 27611-7447: Unless such demands are made, this permit shall be final and binding.
ne
ooeorthCaroiina
Naturally
North Carolina Division of Water Quality 1617 Mail Service Center Raleigh, NC 27699-1617 Phone [phone] Customer Service
Internet: www.ncwaterquality.ore Location: 512 N. Salisbury SL Raleigh, NC 27604 Fax [phone]
An Equal Opportunity/Affirmative Action Employer— 50% Recycled/10% Post Consumer Paper

Mr. Thomas Gibson
April 13, 2006
Page Two
If you need additional information concerning this matter, please contact Mr. Jim Bushardt at
[phone].
Very ly yours,
Charles Stehman, Ph.D., P.G.
Environmental Regional Supervisor II
Jb:cs:pump&haul.406
Cc: Mr. Thomas Drum (Town of Rose Hill)
Wilmington APS Files
Central APS Files

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT, AND NATURAL RESOURCES
RALEIGH
PUMP AND HAUL PERMIT
In accordance with the provisions of Article 21 of Chapter 143, General Statutes
of North Carolina as amended, and other applicable Laws, Rules, and Regulations:
PERMISSION IS HEREBY GRANTED TO
Carolina By -Products (Rose Hill)
Duplin County
for the
temporary operation of a pump and haul operation for transporting treated industrial & domestic
wastewater from the Carolina By -Products spray irrigation lagoon located at Highway 117, Rose
Hill to the Town of Rose Hill Wastewater Treatment Plant influent pumping station with no
discharge of wastes directly to the surface waters, pursuant to the application submitted to the
Department of Environment, and Natural Resources and considered a part of this permit.
This permit shall be effective from the date of issuance until October 13, 2006 and shall be
subject to the following specified conditions and limitations:
1. This permit shall become voidable unless the subject pump and haul activities are carried out
in a manner which has been approved by this Division.
2. This permit is effective only with respect to the nature and volume of wastes described in the
application and other supporting data.
3. The facilities shall be properly maintained and operated at all times.
4. This permit is not transferable. In the event there is a desire for the facilities to change
ownership, or there is a name change of the Permittee, a formal permit request must be
submitted to the Division of Water Quality accompanied by an application fee, documentation
from the parties involved, and other supporting materials as may be appropriate. The
approval of this request will be considered on its merits and may or may not be approved.
127 North Cardinal Dr., Wilmington, North Carolina 28405
An Equal Opportunity Affirmative Action Employer
'telephone [phone] FAX [phone]
50% recycled/10% post consumer paper

Pump & Haul Permit No, WQ0031025
Page Two
5. No type of wastewater other than treated industrial & domestic waste from the Carolina By -
Products Manufacturing Facility, located at Highway 117, Rose Hill, shall be included in the
pump and haul activities.
6. This permit shall become voidable unless the agreements between Carolina By -Products and
the Town of Rose Hill are in full force and effect.
7. In the event that the facilities fail to perform satisfactorily, including the creation of nuisance
conditions, the Permittee shall cease operation of all pump and haul activities, and take such
immediate corrective action as may be required by this Division.
8. This pump and haul permit shall not be renewed. The pump and haul activity shall cease upon
the expiration date of this permit.
9. The treated wastewater collected by this system shall be transferred to the Town of Rose Hill
Wastewater Treatment Plant by Carolina By -Products personnel for ultimate treatment and
disposal in accordance with conditions of the Town's NPDES Permit No. NCO056863 issued
by the Division of Water Quality. Pump & haul transfers to the Town' s influent pumping
station shall be accomplished Monday through Friday between the hours of 9 am to 11 am
and between the hours of 2 pm and 4 pm.
10. The Permittee (Carolina By -Products) is liable for any damages caused by a spill or failure of
the pump and haul operations.
11. Adequate inspection, maintenance, and cleaning shall be provided by the Permittee to insure
proper operation of the subject facilities.
12. The Permittee (Carolina By- Products) or their designee shall inspect the wastewater
collection facilities to prevent malfunctions, deterioration, operator errors, and discharges
which may cause or lead to the release of wastes to the environment, a threat to human
health, or a nuisance. The Permittee shall keep an inspection log or summary including at
least the date and time of inspection, observations made, and any maintenance, repairs, or
corrective actions takers by the Permittee. This log of inspections shall be maintained by the
Permittee for as long as the pump and haul activities are being conducted and shall be made
available upon request to the Division of Water Quality or other permitting authority.
13. Any duly authorized officer, employee, or representative of the Division of Water Quality
may, upon presentation of credentials, enter and inspect any property, premises or place on
or related to the wastewater collection facilities at any reasonable time for the purpose of
determining compliance with this permit and may inspect or copy any records that must be
kept under the terms and conditions of this permit, and may obtain samples.
127 North Cardinal Dr., Wilmington, North Carolina 28405
An Equal Opportunity Affirmative Action Employer
Telephone [phone] FAX [phone]
50% recyeled/10% post -consumer paper

Pump & Haul Permit No. WQ0030125
Page Three
14. An accurate record of the pump and haul activities must be maintained by the Permittee
indicating:
date wastewater is removed from the facility.
name of facility from which wastewater is removed.
name of facility receiving wastewater,
volume of wastewater removed,
status of permanent disposal option.
These records shall be submitted to the Wilmington Regional Office of the Division of
Water Quality located at 127 Cardinal Drive Extension, Wilmington, North Carolina, 28405
on or before the fifteenth (15th) day of the following month.
15. Failure to abide by the conditions and limitations contained in this permit may subject the
Permittee to an enforcement action by the Division of Water Quality in accordance with
North Carolina General Statute 143-215.6A.
16. The issuance of this permit does not preclude the Permittee from complying with any and all
statutes, rules, regulations, or ordinances, which may be imposed by other government
agencies (local, state, and federal), which have jurisdiction.
17. Noncompliance Notification:
The Permittee shall report by telephone to the Wilmington Regional Office at telephone
no.[phone] as soon as possible, but in no case more than 24 hours or on the next
working day following the occurrence or first knowledge of the occurrence of any of the
following:
a. Any failure of equipment, storage or transportation facilities resulting in a by-pass
directly or indirectly to waters or lands of the State.
Persons reporting such occurrences by telephone shall also file a written report within 15
days following first knowledge of the occurrence. This report should be directed to Mr.
Charles Stehman, Ph.D, P.G., Environmental Regional Supervisor II, NCDENR, 127
Cardinal Drive Extension, Wilmington, North Carolina 28405 and must outline the
actions taken to clean up the wastewater and ensure that the problem does not recur.
18. The annual administering and compliance fee must be paid by the Permittee within thirty
(30) days after being billed by the Division, Failure to pay the fee accordingly may cause
the Division to initiate action to revoke this permit as specified by 15 NCAC 2H.
0205. (c)(4).
127 North Cardinal Dr., Wilmington, North Carolina 28405
An Equal Opportunity Affirmative Action Employer
Telephone [phone] FAX [phone]
50% recycled/10% post -consumer paper

Permit issued this 13°i day of April 2006.
NORTH CAROLINA ENVIRONMENTAL MANAGEMENT COMMISSION
Charles Stehman, Ph.D., P. G. �1
Environmental Regional Supervisor II
Permit No. WQ0030125
127 North Cardinal Dr., Wilmington, North Carolina 28405
An Equal Opportunity Affirmative Action Employer
Telephone [phone] FAX [phone]
50% recycled/10% post -consumer paper

f T
F
��Ia
MCDENR
North Carolina Department of Environment and Natural Resources
Division of Water Qualit,
Beverly Eaves Perdue Coleen H. Sullins
Governor Director
October 22, 2009
MR. BILL EHRENBECK, PUBLIC WORKS MANAGER
TOWN OF PLYMOUTH
POST OFFICE BOX 806
PLYMOUTH, NORTH CAROLINA 27962
Subject: Permit No. WQ0030132
Town of Plymouth
Town of Plymouth WWTP
Land Application of Residual
Solids (503)
Washington County
Dear Mr. Ehrenbeck:
Dee Freeman
Secretary
In accordance with your permit modification request received June 10, 2009, we are forwarding
herewith the modified Attachment A for Permit No. WQ0030132, dated October 22, 2009, to the Town of
Plymouth for the subject land application of residuals solids program. Because the Town has fulfilled all
the requirements to reduce the monitoring outlined in Condition 111.3. of the June 22, 2006 permit, the
Division is issuing the Town an updated Attachment A. Please replace this Attachment A dated June 22,
2006 with the new Attachment A.
On August 5, 2009, Session Law 2009-406, entitled "An Act to Extend Certain Government
Approvals Affecting the Development of Real Property Within the State," was enacted by the General
Assembly and signed into law. The Act, known as the Permit Extension Act of 2009, extends the
expiration date of certain government approvals and permits. This permit, WQ0030132, issued by the
Division of Water Quality falls within the scope of this Act and is therefore being extended until June 22,
2014. Please pay particular attention to the monitoring requirements in this permit. Failure to establish
an adequate system for collecting and maintaining the required operational information will result in
future compliance problems.
Please pay particular attention to the monitoring requirements in this permit. Failure to establish
an adequate system for collecting and maintaining the required operational information will result in
future compliance problems. Please note that the monitoring required for Condition III.3, has been
changed from quarterly to annually. In the future, when the Town submits annual reporting forms and
laboratory analyses to the Division, please insure that all documentation has a signed certification
statement.
If any parts, requirements, or limitations contained in this permit are unacceptable, you have the
right to request an adjudicatory hearing upon written request within thirty (30) days following receipt of
this permit. This request must be in the form of a written petition, conforming to Chapter 150B of the
AQUIFER PRCTECTIO SFCTIUI
1636 Mail Service Cente% Raleigh, North Carolina 27699-1636
Locabn 2728 Capital Boulevard, Raleigh, NoO Carolina 27604 One
919-733-32211 FAX 1: 919.715-0588; FAX 2: 919-715-60481 Customer Service: 1-B77.623-6741 N On th C�.Oj s 11�
Internet: www.ncM10u@Ifty.0rq .n
Ai EGuc. Cnocrrunil,, � 4fhmtatve,, ion Employe � �

Mr. Ehrenbeck
October 5, 2009
Page 1 of 1
North Carolina General Statutes, and filed with the Office of Administrative Hearings, 6714 Mail Service
Center, Raleigh, NC 27699-6714. Unless such demands are made this permit shall be final and binding.
Please note that on September 1, 2006 State Administrative Code 15A NCAC Subchaptcr 02T —
Waste not Discharged to Surface Water was adopted. The Town's renewed permit in 2014 will
incorporates the requirement of these rules.
If you need additional information concerning this matter, please contact Alice M. Wessner at
[phone] or [e-mail].
Sincerely,
der Coleen H. Sullins
cc: Washington County Health Department
Washington Regional Office, Aquifer Protection Section
C. Scott Carpenter, Soils Plus, LLC, 1308 Hope Drive, Greenville, NC 27858
Permit File WQ0030132
Notebook pile WQ0030132

ATTACHMENT A - Approved Residual Sources
Permit No. WQ0030132
Town of Plymouth — Town of Plymouth LARS
Certification Date. 10/22/2009
Maximum
Monitoring
Monitoring Frequency
Approved
Permit
Dry Tons
Frequency for
for Condition Ill. 3.
Mineralization
Owner
Facility Name
County
Number
Issued By
Is 503?
Per Year
Condition III.2. &
and Condition Ill. 4. a
Rate
Town of
Town of
Plymouth
Washington
NC0020028
DWQ
Yes
85.1
Annually
Annually
30
Plymouth
W WTP
Total
�S•1
a Monitoring frequencies are based on the actual dry tons applied per year, unless otherwise specified.
WQ0030132 Version 1.2 ATTACHMENT A Page I of 1

WQ004####Version #.# Shell Version 090204 Page 1 of##

1177
N
NO-
♦� v WWk—
� 1332 )1
- r
„ 1116 1300 328 1329 /
L
s r.
w � 32'!",
1116
6-
to
�--� ;°• ; /' 1112�' a 1123
— \ a 1211
tir ?
J20D
11B SI Q 11�B 1195
O
_L 1
1Gna 1104
- 1 _
1400 i174
�\ L
w -7 d°
1127 /
1103 \ I \ s
1100 a_
12
SITE 2 V � • • � � ,' ,
a
g� 1
S� b
/ C O U N T Y
BEAUFORT
2 1 0 2
Souxcr: County map provided by NCDOT Mikes
'tale: 1 inch equals 2 nudes
�-
PLUS
LOCATION MAP - SITE 2
FIGURE
Drawn bT CSC
Washington County, North Carolina
Reviewed by:
Town of Plymouth Residual Program
Date: March -'07
Soil Plus Project No. 200701.All

a 711.
r_. j.
n
CCiT1 } 4lVjOc
$M -' hristiare lope I l'
� u
e
a A
if
� g A
!f
1 ' r,
e
n! !
1 _
wy
�?r t
e d 3
.sn�{''�. r,
.� 4q
f G iJ
Cinil
1
r i
x36
=d-=-- -- - 7.•: LEGEND
2,000 1,000 0 2,000
_ = Field boundary
��_Ce SGS TOP°BT-Phy rrsap provided by N®GT ' r ~ Feet,,
A ! A%'
Scale: 1 inch equals 2,000 feet USGS TOPOGRAPHY MAP FIGURE
Drawn by: CSC „t. Washington County, North Carolina
Renewed by:'f Town of Plymouth Residual Program
���� , w w PLUS
Date: March - 07 5oi1 Plus Project No. 2007011',11

w
WheCiet C]'pTg7�IrFI, /
■ 4 ; �
Wcycrbacuaer Comp.ny
1 �
/ 7*
Soil Boring
3.78 Net Acme
Field 1
/ yy�
7f'
M.rjork Mi-cl �l
7heeier Gurgauos
i
Che.roo
, 1 v
j � I
49 1
i�
Support Wires for anteana f
/ /Marjorie Miz.1k
1 � �
1 i �
Marjorie Maellc / I
-"emu
All I *Y
5,14Net Aeres Field ® /
Soil Boring 2 _
Source: Buffers are in accordance with 15A NCAC ZT .1108 (b) (2)
Road and contours provided by NCDOT
Property boundary approxirmted from Washington County GTS
I I
I I
i�
�l I
200 100 0 200
iiiiiiiiii Feet
r
Scale: I inch equals 200 feet rFn,: f BUFFER MAP - SITE 2 FIELD I FIGURE
Drawn by. CSC Washington County, North Carolina
Reviewed by: SOIL Town of Plymouth Residual Program 4
Date: March - '07 ., Soil Plus Ptoject No. 200701.A11

Weyetiamaer company
/ Mar;ane M�ru<
11
Soil Baring 3
9-BUJet Acres Field
satlsar:ttg:t®
8.79 Net Acres Field l
A
Sod Bating 2 /
I / /
SA Net At— Field 2 / Marjorie Mucur
(/
/ 1A l er l
Source: Buffers arc in accordance with 15A NCAC 7T' .1108 (b) (2)
Road and contours provided by NCDOT
Property boundnT approximated fmm Washington County GIS
Scale: 1 inch equals 200 feet
Drawn by: CSC
,i
Reviewed by:
Date: March - '07
w ying ectnca wires
Marjorie MizelLe
200 100 fl 200
Feet
'*al��'
i SOIL
-PLUS
BUFFER MAP - SI`L'E 2 FIELD 2 FIGURE
Washington County, North Carolina
Town of Plymouth Residual Program 5
Soil Plus Project No. 200701Al1