WQ0024926_Final Permit_20050825

Michael F. Easley, Governor
William G. Ross Jr., Secretary
North Carolina Department of Environment and Natural Resources
Alan W. Klimek, P.E., Director
Division of Water Quality
August 25, 2005
Eddie Uzzell
Atlantic Water Works
PO Box 1913
Goldsboro, NC 27530
Subject: Permit No. WQ0024926
Atlantic Water Works
Wastewater Recycle System
Onslow County
Dear Mr. Uzzell:
In accordance with your permit application received February 9, 2005, and subsequent additional
information received March 18, 2005 and June 23, 2005, we are forwarding herewith Permit No. WQ0024926,
dated August 25, 2005, to Eddie Uzzell for the construction and operation of the subject wastewater recycle
system.
This permit shall be effective from the date of issuance until July 30, 2010, and shall be subject to the
conditions and limitations as specified therein. Please pay particular attention to the monitoring requirements in
this permit. Failure to establish an adequate system for collecting and maintaining the required operational
information will result in future compliance problems.
If any parts, requirements, or limitations contained in this permit are unacceptable, you have the right to
request an adjudicatory hearing upon written request within thirty (30) days following receipt of this permit. This
request must be in the form of a written petition, conforming to Chapter 150B of North Carolina General Statutes,
and filed with the Office of Administrative Hearings, 6714 Mail Service Center, Raleigh, NC 27699-6714.
Unless such demands are made this permit shall be final and binding.
One set of approved plans and specifications is being forwarded to you. If you need additional
information concerning this matter, please contact Michelle McKay [phone].
Sincerel
.Alan W. Klimek, P.E.
cc: Wilmington County Health Department
Raleigh Regional Office, Aquifer Protection Section
Michael C. Gallant, PE, PA
Technical Assistance and Certification Unit
APS Central Files one
LAU Files NorthCarolina
Naturally
Aquifer Protection Section I636 Mail Service Center Raleigh, NC 27699-1636 Phone [phone] Customer Service
Internet: h2o.enrstate.nc.us 2728 Capital Boulevard Raleigh, NC 27604 FAX [phone]
An Equal oppoftuniVAttirmative Action Employer — 500% Recycled/101% Post Consumer Paper

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
RALEIGH
RECYCLE SYSTEM PERMIT
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North Carolina as amended,
and other applicable Laws, Rules, and Regulations
PERMISSION IS HEREBY GRANTED TO
Eddie Uzzell
Onslow County
FOR THE
construction and operation of a 2,425 GPD wastewater recycle system consisting of a covered, closed loop
package treatment system including five catch basins, a gravity wastewater collection system, a 1,750 gallon oil
water separator, two 2,000 gallon treatment tanks and filtration equipment with polymer addition and two 2,000
gallon recycle tanks to serve Atlantic Water Works with no discharge of wastes to the surface waters, pursuant to
the application received June 3, 2000, and subsequent additional information received by the Division, and in
conformity with the project plan, specifications, and other supporting data subsequently filed and approved by the
Department of Environment and Natural Resources and considered a part of this permit.
This permit shall be effective from the date of issuance until July 30, 2010, and shall be subject to the
following specified conditions and limitations:
Upon completion of construction and prior to operation of this permitted facility, a certification must be -
received from a professional engineer certifying that the permitted facility has been installed in accordance
with this permit, the approved plans and specifications, and other supporting materials. If this project is to
be completed in phases and partially certified you shall retain the responsibility to track further
construction approved under the same permit, and shall provide a final certificate of completion once the
entire project .has been completed. Mail the Certification to the Division of Water Quality, Aquifer
Protection Section, 1636 Mail Service Center, Raleigh, NC 27699-1636.
2. The Wilmington Regional Office, telephone number [phone], shall be notified at least forty-eight
(48) hours in advance of operation of the installed facilities so that an in -place inspection can be made.
Such notification to the regional supervisor shall be made during the normal office hours from 8:00 a.m.
until 5:00 p.m. on Monday through Friday, excluding State Holidays.
3. This permit shall become voidable unless the facilities are constructed in accordance with the conditions of
this permit, the approved plans and specifications, and other supporting data.
4. This permit is effective only with respect to the nature and volume of wastes described in the application
and other supporting data.
5. The facilities shall be properly maintained and operated at all times.

6. The following buffers shall be maintained:
a) 100 feet between treatment/storage units and any wells,
b) 50 feet between treatment/storage units and surface waters, and
The 50 feet buffer between treatment/storage units and property lines has been removed from the above
maintained buffers in accordance with 15A NCAC 2H .0219 (p), which allows for alternative design
criteria when equal or better treatment of the waste is provided, equal or better protection of the waters of
the state are provided and there is no increased potential for nuisance conditions.
7. This permit is not transferable. In the event there is a desire for the facilities to change ownership, or there
is a name change of the Permittee, a formal permit request must be submitted to the Division of Water
Quality (Division) accompanied by an application fee, documentation from the parties involved, and other
supporting materials as may be appropriate. The approval of the request will be considered on its merits
and may or may not be approved.
8. In the event that the facilities fail to perform satisfactorily, including the creation of nuisance conditions, the
Perrittee shall take immediate corrective action, including those actions that may be required by this
Division, such as the construction of additional or replacement treatment or disposal facilities.
9. The residuals generated from these treatment facilities must be disposed in accordance with General Statute
143-215.1 and in a manner approved by the Division.
10. The issuance of this permit shall not relieve the Permittee of the responsibility for damages to surface or
groundwaters resulting from the operation of this facility.
11. The facilities shall be effectively maintained and operated as a non -discharge system to prevent the
discharge of any wastewater resulting from the operation of this facility.
12. Diversion or bypassing of untreated wastewater from the treatment facilities is prohibited.
13. Any monitoring deemed necessary by the Division to insure surface and ground water protection will be
established and an acceptable sampling reporting schedule shall be followed.
14. Adequate inspection, maintenance, and cleaning shall be provided by the Permittee to insure proper -
operation of the subject facilities.
15. The Permittee or his designee shall inspect the wastewater recycle facilities to prevent malfunctions and
deterioration, operator errors and discharges which may cause or lead to the release of wastes to the
environment, a threat to human health, or a nuisance. The Permittee shall maintain an inspection log or
summary including at least the date and time of inspection, observations made, and any maintenance,
repairs, or corrective actions taken by the Permittee. This log of inspections shall be maintained by the
Permittee for a period of three years from the date of the inspection and shall be made available to the
Division or other permitting authority, upon request.
16. Any duly authorized officer, employee, or representative of the Division may, upon presentation of
credentials, enter and inspect any property, premises or place on or related to the recycle system at any
reasonable time for the purpose of determining compliance with this permit, may inspect or copy any
records that must be maintained under the terms and conditions of this permit, and may obtain samples of
groundwater, surface water, or leachate.
17. The annual administering and compliance fee must be paid by the Permittee within thirty (30) days after
being billed by the Division. Failure to pay the fee accordingly may cause the Division to initiate action to
revoke this permit as specified by 15A NCAC 2H .0205 (c)(4).

18. Failure to abide by the conditions and limitations contained in this permit may subject the Permittee to an
enforcement action by the Division in accordance with North Carolina General Statute 143-215.6A to 143-
215.6C.
19. The issuance of this permit does not exempt the Permittee from complying with any and all statutes, rules,
regulations, or ordinances which may be imposed by other government agencies (local, state, and federal)
which have jurisdiction, including but not limited to applicable river buffer rules in 15A NCAC 2P.0200,
erosion and sedimentation control requirements in 15A NCAC Chapter 4 and under the Division's General
Permit NCGO10000, and any requirements pertaining to wetlands under 15A NCAC 2B .0200 and 2H
.0500.20.
20. A set of approved plans and specifications for the subject project must be retained by the Permittee for the
life of this project.
21. Noncompliance Notification:
The Permittee shall report by telephone to the Raleigh Regional Office, telephone number [phone],
as soon as possible, but in no case more than 24 hours or on the next working day following the occurrence
or first knowledge of the occurrence of any of the following:
a. Any occurrence at the wastewater treatment facility which results in the treatment of significant
amounts of wastes which are abnormal in quantity or characteristic, such as the dumping of the contents
of a basin or tank, the known passage of a slug of hazardous substance through the facility, or any other
unusual circumstances;
b. Any process unit failure, due to known or unknown reasons, that renders the facility incapable of
adequate wastewater treatment, such as mechanical or electrical failures of pumps, aerators,
compressors, etc.;
c. Any failure of a pumping station, sewer line, or treatment facility resulting in a by-pass directly to
receiving waters without treatment of all or any portion of the influent to such station or facility; or
d. Any time that self -monitoring information indicates that the facility is not in compliance with its permit
limitations.
Occurrences outside normal business hours may also be reported to the Division's Emergency Management
personnel at telephone number [phone], or [phone]. Persons reporting such occurrences by
telephone shall also file a written report in letter form within five (5) days following first knowledge of the
occurrence. This report must outline the actions taken or proposed to be taken to ensure that the problem
does not recur.
22. A leakage test shall be performed on all tanks to insure that any exfiltration occurs at a rate which does not
exceed twenty (20) gallons per twenty-four (24) hours per 1,000 gallons of tank capacity. The engineer's
certification will serve as proof of compliance with this condition.
23. Upon classification of the wastewater treatment and spray irrigation facilities by the Water Pollution
Control System Operators Certification Commission (WPCSOCC), the Permittee shall designate and
employ a certified operator to be in responsible charge (ORC) and one or more certified operator(s) to be
back-up ORC(s) of the facilities in accordance with 15A NCAC 8G .0201. The ORC shall visit the
facilities in accordance with 15A NCAC 8G .0204 or as specified in this permit and shall comply with all
other conditions specified in these rules.

24. The Permittee, at least six (6) months prior to the expiration of this permit, shall request its extension.
Upon receipt of the request, the Commission will review the adequacy of the facilities described therein,
and if warranted, will extend the permit for such period of time and under such conditions and limitations as
it may deem appropriate.
Permit issued this the2.5"' day of August, 2005
NORTH C OL1NA E ONMENTAL MANAGEMENT COMMISSION
Alan W. Klimek, P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission
Permit Number WQ0024926
4

Permit No. WQ0024926
August 25, 2005
ENGINEER'S CERTIFICATION
Partial Final
I, , as a duly registered Professional Engineer in the State of
North Carolina, having been authorized to observe (periodically, weekly, full time) the construction of the project,
Project Name
Location and County
for the Permittee hereby state that, to the best of my abilities, due care and diligence was used in the observation
of the construction such that the construction was observed to be built within substantial compliance and intent of
this permit, the approved plans and specifications, and other supporting materials.
Signature
Date
Registration No.

Atlantic Car Wash
WQ0024926
f •'`� �p
9
4{ II
Hwy 172 _
2!�
Site Location
Hwy 210
v �^
5�
2,000 1,000 0 2,000 Feet N
W � E
S

V7�•

Mj
C.
•+t ,i{J �ll,l,�"•w..IN'r '� I •e'�• ,,y<•'.r „! ; �.`�y"'� 1s�r•, '
Ii,.eIL
r 1
AA
Jr
� rr
�•l1 m J •i fg.�IJ,u • A-:i 1, j t�'' Yf• j,•'�''
I•� �'''r 3 CI.111 Jib,,,• I�� I 1 ,v .r
24.
,�, •, , ��� ''11' ./.. '�!. ,tit�� ; C of �a
a i S•r"" � f �j it 1 4. � I
`•lo. ^ice'• ' r ,`�i.
�=��•it'�•••'�"US:IC:f,���y�.rr��••�I� 'ice-�j�.-�'t..•�.
+_. •k,W,!' ' `,,•tr i; ^'j" •�•- jf;�," .'i..; �P::I�r 1. •f' ' �,
�.':L :.'".t:��- ,•,j + S k�� •�' ��,, (,, � I�rr��°'?r_ ,� .+.••.'� k � . ; •,r •� �1'1, t,tl C.0
'ff`-, t: �`:,i�,"` �[�/�'� 7 i; ..[ �� •I }F,flE`�r�..`,+ II f' , f.0 l r",, I CL Q �t-
,,F '`'4r"S,' . �, r!.• 4 i %�_j�� ^ri,,� Z
�(� po r;'i p J Ltl
••' • a ' + i' ` .I 1, 1� . 1''V+�',,••3' , /� � 5, 1,� l .+d'y � / Q Q �- k�
in
7.
r�� ,S ��. h 't•;ti`'}.11� r .'! f<L� rF/ EU (� a
:• .-� ►` .�,J,,,y r e< • •� i7.a -'.{ EL `1P � •Jr j 'I+, . f F �Z,, ,1 = , ' U a idjD
lf.
'�,~ �. ��.•','' t,..'' ); � ..�'y'��L,f S�.}� Z �, � .'�'•�, f,s • ,�^ e�i"�+I% may`,` O 0 Q �
•, �I ti It;��.IN 4QZ'�ti`{4 `;'iQ`,'i, ' „��J ts�•.J ,'•r••'/' IQ ;t �'':>� �, ' ,_.,� z n ?•' 3
it
•��. •',,• , ,1/, - .l+. •I'f�'!g:•.' '` ram' •''•�.. I "' `.,• - , -"I O
'� ,Y, •,S•; .'•`` '1 ,,�rdi,• , �°•'•:.��f�' � ,�" • 'fY'�'f �l 't r' � , � .... r r •rl ... '' 7• r 11 ' it - •1 �17 •'` 1, �`l \ •, N� FIB, .�.. -c, h K,i
!'lri'. 1'�.'�4•- 1'•�Orv�1'"••-`•%,'1 •I,�j 3/ •tip .r. ��' % 1„�` S ., .I
+ +' }'1,1{'.Fiif`1
st'' ,..1'" (li�,;f•�'•tr: ''Y!:i�' �,F .,^'�rl7il:'+� i ../.,: IL. r , n i ;: i.'
p ,i n4P1.• lb 'pUr� I�,4,$�..1." , ti r•, r. I,-•r J Jta¢ ��' `ri3lnr+�`••,.�-•}1 'i' '� .%
rTJ"
'� II' - - � o c q�'' �p , ,{•„ ;,•'�'' g. j+'' �.•al �o( IL'
1E , •';'T'•• j,, , -y� •,.
�•y� ••}Cbl:~ti' � ,a,q +.Y •�j..� i'li,'�11 ''I�,�W�I'•Yf/: Y if� sY '` 1�-'�':j '�ti•*" ,1 �.rf (f ft
v ,E , `' •� .5�'�f ' L,"F+�• '.L:11p � • ' � •S�'� ^ram"' �� � �' '��\,
�ti JU k a 15 f
:fi; �T`'~ .'r,`' �!„^ 1 �: { „;,lU- '11 tl ' ?�'i• tr I % n
`,f i'G ' ��' is • 1` r '.,, /L L i�y;'i 3n
� � ���.1�� 4. "! s' ' ""�• fil �• c11 ,�. � i� ���r� uri
Q-
114
s'l(�
�'t l+��l L,.j -1; �' fJ r- ��1t ' •. �. Q
, �, j
,)l�'; rr L I / •1 1,r �� ( 1" t y �1'. �I ^L ! �'�
.'� s •1.•r +�lp" �,�' F ,{ fujti•'0r� �3,•E' 1�///���yffff [�„rt+ f`�`'
At + :j ,,. • less �- V �� '�, �'•r ' ` I 1 T Fsl
's•. • � r
iliilf#'� r+i i+ T.� �" L1 1r•, { i {jam (�• f/1
is, 431 ;�\)u {Y';=;:;:. .i , ' ii.'7 y �+lr ! ♦.ti,ti;,{ ' l , '' 1y.1:•f-4 i} Ir,
i --ir r%•' %' .` ! i +:��`)�f� ,:_tetiJ.,fr']I f y '.ir•a y `��. le>; �11
. .rJ,y—`�;lnlli�r+'' o f r ,ice s
:v�Uft1J'�;•'i_ i t :+i:s i' � =•:j'll' :',r',I �.:_. .s.l, :;, �� j„ IQ\
xjj�``t J?, , A!�. ,
y��... �� i C�kr• �d;�.. , 1 ,4 .r•o ' ,r=' _
r � .�. s :� 1..-.�--_1... r. ..a ��..._.�'.5:.•..�a.. :iir�t.��l: �.._l_r;•—•---._.. �w''`-- f., .__....-. —
�l6emarle
b