WQ0008907_Final Permit_19990730

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
Kerr T. Stevens, Director
July 30, 1999
Charles E. Marks, Director of Quality
Gaston County Dyeing Machine Company
Post Office Box 308
Stanley, NC 28164
Dear Mr. Marks:
NCDENR
NORTH CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Permit No. WQ0008907
Gaston County Dyeing Machine Co.
Stanley Plant
Groundwater Remediation Facilities
Gaston County
In accordance with your application received March 2, 1999, we are forwarding herewith Permit No.
WQ0008907, dated July 30, 1999, to the Gaston County Dyeing Machine Company for the continued
operation of the subject groundwater rernediation facility.
This permit shall be effective from the date of issuance until June 30, 2004, shall void Permit No.
WQ0008907 issued February 6, 1997, and shall be subject to the conditions and limitations as specified
therein. Please pay particular attention to the Groundwater Monitoring requirements in this permit as they are
slightly different than the previous permit. Failure to establish an adequate system for collecting and
maintaining the required operational information will result in future compliance problems.
If any parts, requirements, or limitations contained in this permit are unacceptable, you have the right
to request an adjudicatory hearing upon written request within thirty (30) days following receipt of this permit.
This request must be in the form of a written petition, conforming to Chapter I50B of the North Carolina
General Statutes, and filed with the Office of Administrative Hearings, P.O. Drawer 27447, Raleigh, NC
27611-7447. Unless such demands are made this permit shall be final and binding.
If you have any questions concerning the Groundwater Conditions or groundwater monitoring
requirements, please contact David Goodrich in the Groundwater Section at [phone]. If you need any
additional information concerning this matter, please contact Dianne Thomay�t [phone] extension 364.
r
Kerr T. Stevens
cc: Gaston County Health Department
Robert Hird, Cooper Environmental
MRO, Water Quality Section
MRO, Groundwater Section
GWS, Central Office
Technical Assistance and Certification Unit
Non -Discharge Compliance/Enforcement Unit
l�
1617 Mail Service Center, Raleigh, NC 27699-1617 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
RALEIGH
GROUNDWATER REMEDIATION AND INJECTION WELL PERMIT
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North Carolina as
amended, and other applicable Laws, Rules, and Regulations
PERMISSION IS HEREBY GRANTED TO
Gaston County Dyeing Machine Company
Gaston County
FOR THE
continued operation of a 4,320 GPD groundwater remediation facility consisting of one (1) recovery well, a
500 gallon influent holding tank, dual carbon adsorption units in series, an effluent totalizing flow meter and
one (1) injection well to serve Gaston County Dyeing Machine Company, with no discharge of wastes to the
surface waters, pursuant to the application received March 2, 1999, and in conformity with the project plan,
specifications, and other supporting data subsequently filed and approved by the Department of Environment
and Natural Resources and considered a part of this permit.
This permit shall be effective from the date of issuance until June 30, 2004, shall void Permit No.
WQ0008907 issued February 6, 1997, and shall be subject to the following specified conditions and
limitations:
I. PERFORMANCE STANDARDS
This permit shall become voidable if the soils fail to adequately assimilate the wastes and may be
rescinded unless the facilities are installed, maintained, and operated in a manner which wiR
protect the assigned water quality standards of the surface waters and ground waters.
In the event that the facilities fail to perform satisfactorily, including the creation of nuisance
conditions, the Permittee shall take immediate corrective action, including those actions that may
be required by the Division of Water Quality (Division), such as the construction of additional or
replacement treatment or disposal facilities.
The issuance of this permit shall not relieve the Permittee of the responsibility for damages to
surface or groundwaters resulting from the operation of this facility.
4. Any residuals generated from these treatment facilities must be disposed in accordance with
General Statute 143-215.1 and in a manner approved by the Division.
Diversion or bypassing of the untreated groundwater from the treatment facilities is prohibited.

II. OPERATION AND MAINTENANCE REQUIREMENTS
1 _ The facilities shall be properly maintained and operated at all times.
2. Upon classification of the facility by the Water Pollution Control Systems Operators Certification
Commission (WPCSOCC), the Permittee shall employ a certified wastewater treatment plant
operator to be in responsible charge (ORC) of the wastewater treatment facilities. The operator
must hold a certificate of the type and grade at Ieast equivalent to or greater than the classification
assigned to the wastewater treatment facilities by the WPCSOCC. The Permittee must also
employ a certified back-up operator of the appropriate type and grade to comply with the
conditions of 15A NCAC 8A .0202. The ORC of the facility must visit each Class I facility at
least weekly and each CIass 11, III, and IV facility at least daily, excluding weekends and
holidays, and must properly manage and document daily operation and maintenance of the
facility and must comply with all other conditions of ISA NCAC 8A .0202
The facilities shall be effectively maintained and operated as a non -discharge system to prevent
the discharge of any wastewater resulting from the operation of this facility.
III. MONITORING AND REPORTING RE UIREMENTS
1. Any monitoring deemed necessary by the Division to insure surface and ground water protection
will be established and an acceptable sampling reporting schedule shall be followed.
2. Noncompliance Notification:
The Permittee shall report by telephone to the Mooresville Regional Office, telephone number
(704) 663- I 699, as soon as possible, but in no case more than 24 hours or on the next working
day following the occurrence or first knowledge of the occurrence of any of the following:
a. Any occurrence at the groundwater remediation facility which results in the treatment of
significant amounts of contaminated groundwaters which are abnormal in quantity or
characteristic, such as the dumping of the contents of a basin or tank, the known passage of a
slug of hazardous substance through the facility, or any other unusual circumstances;
b. Any process unit failure, due to known or unknown reasons, that renders the groundwater
treatment and disposal system incapable of adequate treatment and disposal, such as
mechanical or electrical failures of pumps, aerators, compressors, etc.;
c. Any failure of a pumping station, sewer line, or treatment facility resulting in a by-pass
directly to receiving waters without treatment of all or any portion of the influent to such
station or facility; or
d. Any time that self -monitoring information indicates that the groundwater treatment and
disposal system is not in compliance with any specified permit Iimitations.
Persons reporting such occurrences by telephone shall also file a written report in letter form
within five (5) days following first knowledge of the occurrence. This report must outline the
actions taken or proposed to be taken to ensure that the problem does not recur.
IV. GROUNDWATER REQUIREMENTS
1. For the purposes of reporting groundwater monitoring results, monitor well MW-7b shall be
designated as MW-7.

2. Existing monitor wells MW-3, MW-5, MW-7, MW-14 and MW-16 shall be sampled every
October for the following parameters:
Water Level pH
Nitrate Nitrogen EPA Method 624
Existing monitor well MW-11 shall be sampled every October for Water Level, pH and Nitrate
Nitrogen.
The measurement of water levels must be made prior to sampling for the remaining parameters.
The depth to water in each well shall be measured from the surveyed point on the top of the
casing.
The results of the sampling and analysis must be received on Form GW-59 (Groundwater
Quality Monitoring: Compliance Report Form) by the Groundwater Section, Permits and
Compliance Unit, P.O. Box 29578 Raleigh, N.C. 27626-0578 on or before the fast working
day of the month following the sampling month.
3. The influent and effluent from the treatment system, shall be sampled every April and October for
the parameters specified below:
pH Nitrate Nitrogen
EPA Method 624
The results of the sampling and analysis must be received on Form GW-59 (Groundwater
Quality Monitoring: Compliance Report Form) by the Groundwater Section, Permits and
Compliance Unit, P.O. Box 29578 Raleigh, N.C. 27626-0578 on or before the last working
day of the month following the sampling month.
4. Any additional groundwater quality .monitoring, as deemed necessary by the Division, shall be
provided.
5. The COMPLIANCE BOUNDARY for the disposal system is specified by regulations in 15A
NCAC 2L, Groundwater Classifications and Standards. The Compliance Boundary is for the
disposal system constructed after December 31, 1983 is established at either (1) 250 feet from the
waste disposal area, or (2) 50 feet within the property boundary, whichever is closest to the waste
disposal area. An exceedance of Groundwater Quality Standards at or beyond the Compliance
Boundary is subject to immediate remediation action in addition to the penalty provisions
applicable under General Statute 143-215.6A(a)(1).
In accordance with 15A NCAC 2L, a REVIEW BOUNDARY is established around the disposal
systems midway between the Compliance Boundary and the perimeter of the waste disposal area.
Any exceedance of standards at the Review Boundary shall require remediation action on the part
of the permittee.
6. The groundwater recovery, treatment and disposal system shall be inspected weekly. If it is
determined that the system is malfunctioning, all repairs should be made as soon as possible and
reported to the Mooresville Regional Office within 48 hours.
7. The groundwater treatment system shall comply with the groundwater quality standards of 15A
NCAC 2L .0202 prior to discharge to the injection. well. If the treatment system fails to
consistently achieve this standard, additional treatment units or changes in operational methods
may be required.

8. Isoconcentration (lines connecting points of equal concentration) maps in both the vertical and
horizontal directions shall be developed using the October groundwater monitoring data for
Nitrate nitrogen and VOCs (EPA Method 624 parameters (totaled)). A water level contour map
must also be developed on an annual basis. These maps shall be submitted along with all other
monitoring data for that period to the Groundwater Section, NC Division of Water Quality, PO
Box 29578, Raleigh, NC 29626-0578.
9. The permittee shall submit a report outlining the injection volumes and pressures of the injection
wells. This report may be submitted along with all other monitoring data.
10. The permittee shall retain copies of records of all monitoring information, including all
calibration and maintenance records, all original strip chart recordings for continuous monitoring
instrumentation and copies of all reports required by this permit, for a period of at least 3 years
from the date of the sample, measurement, report or application. Records of this monitoring
information shall include, but not be limited to, the following:
a. the date, exact place, and time of sampling or measurements,
b. - the individual who performed the sampling or measurements,
c. the date the analyses were performed,
d. the analytical techniques or methods used, and
e. the results of any such sampling, measurements, and analyses.
11. The pernuttee shall report any monitoring or other information which indicates that any
contaminant may cause an endangerment to an underground source of drinking water and any
noncompliance with a permit condition of malfunction of the injection system which may cause
fluid migration outside the injection zone or area. The information shall be provided to the
Mooresville Regional Office orally within 8 hours of the occurrence and as a written submission
within five days of the occurrence. The written submission shall contain a description of the
noncompliance and its cause, the period of noncompliance, including exact dates and times, and
if the noncompliance has not been corrected, the anticipated time it is expected to continue, and
any steps taken or planned to reduce, eliminate and prevent reoccurrence of the noncompliance.
V. INSPECTIONS
1. Adequate inspection, maintenance and cleaning shall be provided by the Permittee to insure
proper operation of the subject facilities.
2. The Permittee or his designee shall inspect the groundwater recovery and treatment facilities to
prevent malfunctions and deterioration, operator errors and discharges which may cause or lead to
the release of wastes to the environment, a threat to human health, or a nuisance. The Permittee
shall maintain an inspection log or summary including at least the date and time of inspection,
observations made, and any maintenance, repairs, or corrective actions taken by the Permittee.
This log of inspections shall be maintained by the Permittee for a period of three years from the
date of the inspection and shall be made available to the Division or other permitting authority,
upon request.
Any duly authorized officer, employee, or representative of the Division may, upon presentation
of credentials, enter and inspect any property, premises or place on or related to the disposal site
or facility at any reasonable time for the purpose of determining compliance with this permit, may
inspect or copy any records that must be maintained under the terms and conditions of this
permit, and may obtain samples of groundwater, surface water, or leachate.
4

V1. GENERAL CONDITIONS
This permit shall become voidable unless the facilities are constructed in accordance with the
conditions of this permit, the approved plans and specifications, and other supporting data.
2. This permit is effective only with respect to the nature and volume of wastes described in the
application and other supporting data.
3. This permit is not transferable. In the event there is a desire for the facilities to change
ownership, or there is a name change of the Permittee, a formal permit request must be submitted
to the Division accompanied by an application fee, documentation from the parties involved, and
other supporting materials as may be appropriate. The approval of this request will be considered
on its merits and may or may not be approved.
4. A set of approved plans and specifications for the subject project must be retained by the
Permittee for the Iife of this project.
5. Failure to abide by the conditions and limitations contained in this permit may subject the
Permittee to an enforcement action by the Division in accordance with North Carolina General
Statute 143-215.6A to 143-215.6C.
6. The annual administering and compliance fee must be paid by the Permittee within thirty (30)
days after being billed by the Division. Failure to pay the fee accordingly may cause the Division
to initiate action to revoke this permit as specified by 15A NCAC 2H .0205 (c)(4).
7. The issuance of this permit does not preclude the Permittee from complying with any and all
statutes, rules, regulations, or ordinances which may be imposed by other government agencies
(local, state, and federal) which have jurisdiction.
8. The Permittee, at least six (6) months prior to the expiration of this permit, shall request its
extension. Upon receipt of the request, the Commission will review the adequacy of the facilities
described therein, and if warranted, will extend the permit for such period of time and under such
conditions and limitations as it may deem appropriate.
Permit issued this tl4 30th day of July 1999
NORTH OLINA E ENTAL MANAGEMENT COMMISSION
Kerr T. Stevens, Director
Division of Water Quality
By Authority of the Environmental Management Commission
Permit Number WQ0008907
5

SCALE 1:24 0OU
y1 „ , IIILE
Itm 0 loon 7oov ,�000 loop 5oov NIX Iwo Iltl
! 1 ! Q � kILOlILIIR
fill 00141OU11 INTERVAL 20 rEET
DAIU11 IS MEA11 SEA LEVEL ^k II.G j
_ _1.
11 "ILI �'�1
lVIC
LIM 11110 .110 IfM µA111101C IIOTIIi
UICLIHAIIOH At ClNllll Of 111M
•
Pump and Treat System Location
gUADRAIIOLE LMUKRI
.'Surface Water Flow Direction
to unnamed tributary of MOUNT HOLLY, I
AIauney Creek.
W A�t`S`��,,
FIGURE I
GASTON COUNTY DYEING MACHINE COMPANY
GROUNDWATER REMEDIATION SYSTEM
GASTON COUNTY
WQ0008907/G_W99097
SITE LOCATION MAP

1
11 1
11 1`
1
1
1
1 1
l� � 1
rE �
1�
6
1
(L 1
` . RFC(NERY W IL tOfAl"JS
INJ(Clx»t W K
PROM" I K(E
-, -• -.— cruel I*w llIICE
POW,, lK(E
JT
f HTly
.�nU aIII III . II Wit !l1 %,n I%"I'$I If%
FIGURE 2
GASTON COUNTY DYEING MACHINE COMPANY
GROUNDWATER REMEDIATION SYSTEM
GASTON COUNTY
WQ0008907 GW99097
SITE DETAIL MAP