WQ0008778_Final Permit_19990111

State of North Carolina
bepartment of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
January 11, 1999
Richard N. Hicks
Town of Farmville
P.O. Box 86
Farmville, North Carolina 27828
"" . V
Ilk
1"'M61
• 2
NCDENR
NORTH ,CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Permit No. WQ0008778
Town of Farmville
Land Application of Wastewater Residuals
Pitt County
Dear Mr. Hicks:
In accordance with your application received on August 13, 1998, we are forwarding herewith Permit No.
WQ0008778, dated January 11, 1999, to the Town of Farmville for the operation of a wastewater residuals land
application program. The application indicates the facility used the Specific Oxygen Uptake Rate (SOUR) test to
prove Vector Attraction Reduction (VAR) compliance. This test is not appropriate for thickened sludge. The town
of Farmville must use an alternate method to prove VAR compliance. As per the attached letter dated November
17, 1998, SOUR may only be used if all of the conditions are met as outlined in the document.
This permit shall be effective from the date of issuance until December 31, 2003, shall void Permit No.
WQ0008778 issued March 31, 1994, and shall be subject to the conditions and limitations as specified therein.
Please pay particular attention to the monitoring and reporting requirements contained in this permit. Failure to
establish an adequate system for collecting and maintaining the required operational information will result in
future compliance problems.
If any parts, requirements, or limitations contained in this permit are unacceptable, you have the right to
request an adjudicatory hearing upon written request within thirty (30) days following receipt of this permit. This
request must be in the form of a written petition, conforming to Chapter 150E of North Carolina General Statutes,
and filed with the Office of Administrative Hearings, P.O. Drawer 27447, Raleigh, NC 2761 I-7447. Unless such
demands are made this permit shall be final and binding.
PO Box 29535, Raleigh, North Carolina 27626-0535 -telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled110% post -consumer paper

If you need additional information concerning this WSincere,
ontact Ron Palumbo at [phone]
extension 533.
A. PrestonHoward, Jr., P.E.
cc: Pitt County Health Department
Washington Regional Office, Water Quality Section
Washington Regional Office, Groundwater Section
Bob Cheek, Groundwater Section, Central Office
Technical Assistance and Certification Unit
Non -Discharge Compliance/Enforcement Unit
AMSCO

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
RALEIIGH
RESIDUALS LAND APPLICATION PERMIT
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North Carolina as amended, and
other applicable Laws, Rules, and Regulations
PERMISSION IS HEREBY GRANTED TO
'own of Farmville
Pitt County
FOR THE
operation of a wastewater residuals land application program consisting of the application of 500 dry tons per year
of residuals from sources listed in Condition II 5, to approximately 70.5 acres of land in Pitt County with no
discharge of wastes to the surface waters, pursuant to the application received on August 13, 1998 and in
conformity with the project plan, specifications, and other supporting data subsequently filed and approved by the
Department of Environment and Natural Resources and considered a part of this permit.
This permit shall be effective from the date of issuance until December 31, 2003, shall void Permit No.
WQ0008778 issued March 31, 1994 and shall be subject to the following specified conditions and limitations:
I. PERFORMANCE STANDARDS
I. The Washington Regional Office, telephone number [phone], and the appropriate Iocal
governmental official (county manager/city manager) shall be notified at least twenty-four (24) hours
prior to the initial application of the residuals to a site so that an inspection can be made of the
Y application sites and application method. Such notification to the regional supervisor shall be made
r during the normal office hours from 8:00 a.m. until 5:00 p.m. on Monday through Friday, excluding
State Holidays. In addition, the Pitt County Manager's office must be notified prior to the initial
application so that they will be aware that the operation has commenced.
2. This permit shall become voidable if the soils fail to adequately assimilate the wastes and may be
rescinded unless the sites are maintained and operated in a manner which will protect the assigned
water quality standards of the surface waters and ground waters.
3. The land application program shall be effectively maintained and operated as a non -discharge system to
prevent the discharge of any wastes resulting from the operation of this program.
4. The issuance of this permit shall not relieve the Permittee of the responsibility for damages to surface
or groundwaters resulting from the operation of this program.

5. In the event that the land application program is not operated satisfactorily, including the creation of
nuisance conditions, the Permittee shall cease applying residuals to the sites and take any immediate
corrective actions as may be required by the Division of Water Quality (Division).
Some of the buffers specified below may not have been included in previous permits for this land
application operation. However, any sites or fields that are included in this permit, but were approved
with different applicable buffers shall be reflagged to comply with the below buffers. The following
buffer zones shall be maintained:
a) 400 feet from residences or places of public assembly under separate ownership for surface
application method; however, the buffer zone requirement may be reduced to a minimum of 100
feet upon written consent of the owner and approval from the appropriate regional office,
b) 200 feet from residences or places of public assembly under separate ownership for subsurface
residual injection method; however, the buffer zone requirement may be reduced to a minimum of
100 feet upon written consent of the owner and the appropriate regional office,
c) 100 feet from any public or private water supply source, waters classified as SA or SB, and any
Class I or Class 11 impounded reservoir used as a source of drinking water for both methods,
d) 100 feet from any streams classified as WS or B, any other stream, canal, marsh or coastal waters
and any other lake or impoundment for surface application,
e) 50 feet from any streams classified as WS or B, any other stream, canal, marsh or coastal waters
and any other lake or impoundment for subsurface application,
f) 50 feet from property lines for both surface and subsurface application methods;
g) 50 feet from public right of ways for both application methods,
h) 10 feet from upslope interceptor drains and surface water diversions for both application methods,
i) 25 feet from downslope interceptor drains, surface water diversions, groundwater drainage systems
and surface drainage ditches for both application methods.
7. A copy of this permit shall be maintained at the land application site when residuals are being applied
during the life of this permit. A spill prevention and control plan, shall be maintained in allresiduals
transport and application vehicles.
8. Specific residual application area boundaries shall be clearly marked on each site prior to and during
application.
9. No residuals at any time shall be stored at any application site, unless approval has been requested and
obtained from the Division.
10. Maximum slope for residual application shall be 10% for surface application and 18% for subsurface
�= applications.
11. When wastewater residuals are applied, the Class A pathogen requirements and site restrictions in 40
CPR Part 503.32(a) or the Class B pathogen requirements and site restrictions in 40 CFR Part
503.32(b), and one of vector attraction reduction requirements in 40 CFR Part 503.33 shall be met.
Additionally, an evaluation must be performed which demonstrates the residuals ability to comply with
this requirement. Upon request, a copy of this evaluation must be submitted including all test results
and calculations.
11. OPERATION AND MAINTENANCE REQUIREMENTS
The facilities and application sites shall be properly maintained and operated at all times.
2. A suitable vegetative cover, as listed in condition II 4, shalI be maintained inaccordance with the crop
management plan outlined by the local Extension Office, the Department of Agriculture, the Natural
Resource Conservation Service, or other agronomist, and approved by this Division.

3, An acceptable pH must be maintained in the soil, residual and lime mixture, greater than 6.0, on all
land application sites to insure optimum yield for the crop(s) specified below, The agronomist shall
provide information on the pH best suited for the specified crop and the soil type.
4
5.
0
7
The application rates (Average based on Realistic Yield Expectation for Goldsboro andNoboco soils)
shall not exceed the followiniz for the specified crony:
Crop
PAN
(lbJaere/yr.}
Crop
PAN
(lb./acre/Yr.)
Bermuda Grass (Hay)
325
Cotton
84
Bermuda Grass (Pasture)
275
Corn
150
Double Crop of Small Grain
(wheat, barley, oats)
50
Soybeans
155
No residuals other than the following are hereby approved for land application in accordance with this
permit:
Permit Volume
Source County Number (dry tons/vearl
Town of Farmville WWTP Pitt NC00029575 500
The metal loading rates shall not exceed the following Cumulative Pollutant loading rates:
Kilograms Pounds
Parameters per Hectare per Acre
Arsenic
41
36
Cadmium
39
34
Copper
1,500
1,338
Lead
300
267
Mercury
17
15
Molybdenum
Nickel
420
374
Selenium
100
89
Zinc
2,800
2,498
The pollutant concentrations in the residuals which will be applied to the land shall not exceed the
following Ceiling Concentrations (Dry Weight Basis):
Parameters me
Arsenic
75
Cadmium
85
Copper
4,300
Lead
840
Mercury
57
Molybdenum
75
Nickel
420
Selenium
100
Zinc
7,500
8. Upon classification of the facility by the Water Pollution Control System Operators Certification
Commission (WPCSOCC), the Permittee shall employ a certified land application/residuals operator to
be in responsible charge (ORC) of the land application program. The operator must hold a certificate
of the type classification assigned to the land application program by the WPCSOCC. The Permittee
must also employ a certified back-up operator of the appropriate type to comply with the conditions of
15A NCAC 8A .0202.
3

9. Adequate procedures shall be provided to prevent surface runoff from carrying any disposed or stored
residuals into any surface waters.
10. Surface applied residuals will be plowed or disced within twenty-four (24) hours after application on
lands with no cover crop established.
11. For areas that are prone to flooding or within the 100-year flood elevation, residuals may be applied
only during periods of dry weather. The residuals must be incorporated into the soil within twenty-four
(24) hours after application.
12. Appropriate measures must be taken to control public access to the land application sites during active
site use and for the 12-month period following the last residual application event. Such controls may
include the posting of signs indicating the activities being conducted at each site.
13. Adequate provisions shall be taken to prevent wind erosion and surface runoff from conveying
pollutants from the residuals application area onto the adjacent property or into any surface waters.
14. Residuals shall not be applied in inclement weather or until 24 hours following a rainfall event of 1/2-
inch or greater in 24 hours. Any emergency residuals disposal measures must first be approved by the
Division.
I5. Residuals shall not be applied to any land application site that is flooded, frozen or snow-covered.
16. Residuals shall not be applied at rates greater than agronomic rates, unless authorized by the Division.
17. Animals shall not be grazed on an application site for 30 days after residuals application. Application
sites that are to be used for grazing shall have fencing that will be used to prevent access after each
application.
18. food crops, feed crops and fiber crops that do not come in contact with the residuals shall not be
harvested for 30 days after residuals application.
19. Food crops with harvested parts that touch the residual soil mixture and are totally above the land
surface (ex. tobacco, melons, cucumbers, squash, etc.) shall not be harvested for 14 months after
residuals application.
20. Food crops with harvested parts below the surface of the land (root crops such as potatoes, carrots,
radishes, etc.) shall not be harvested for 20 months after application of residuals when the residuals
remain on the land surface for four (4) months or longer prior to incorporation into the soil.
Y
21. Food crops with harvested parts below the surface of the land shall not be harvested for 38 months after
application of residuals when the residuals remain on the land surface for Iess than four (4) months
prior to incorporation into the soil.
22. Turf shall not be harvested for 1 year after residuals application if the turf is to be placed on land with a
high potential for public exposure.
23. Due to the presence of salts in the residuals, the exchangeable sodium percentage (ESP) shall be
monitored on the land application sites using the results from the annual soils analysis. The local
Extension Office, the Department of Agriculture, the Natural Resource Conservation Service, or a
North Carolina Licensed Soil Scientist will review the results and make recommendations.
III. MONITORING AND REPORTING REQUIREMENTS

Any monitoring (including groundwater, surface water, residuals, soil, or plant tissue analyses)deemed
necessary by the Division to insure protection of the environment will be established and an acceptable
sampling and reporting schedule shall be followed.
2. Proper records shall be maintained by the Permittee tracking all application activities. These records
shall include, but are not necessarily limited to the following information:
a. source of residuals
b, date of residual application
c. location of residual application (site, field, or zone 4)
d. method of application
e, weather conditions (sunny, cloudy, raining, etc.)
f. soil conditions
g. type of crop or crops to be grown on field
h. volume of residuals applied in gallons/acre, dry tons/acre or kilograms/hectare
i. annual and cumulative totals of dry tons/acre of residuals, annual and cumulative pounds/acre of
each heavy metal (which shall include, but not be limited to arsenic, cadmium, copper, lead,
mercury, molybdenum, nickel, selenium and zinc), annual pounds/acre of plant available nitrogen
(PAN), and annual pounds/acre of phosphorus applied to each field.
A representative annual soils analysis (Standard Soil Fertility Analysis) shall be conducted on each site
receiving residuals in the respective calendar year and the results maintained on file by the Permittee
for a minimum of five years.
The Standard Soil Fertility Analysis shall include, but is not necessarily limited to, the following
parameters:
Acidity
Calcium
Copper
Magnesium
Cation Exchange Capacity
Manganese
Percent Hum is Matter
PH
Phosphorus
Potassium
Sodium
Zinc
Base Saturation (by calculation)
4. A residuals analysis will be conducted quarterly from the date of permit issuance by the Permittee and
the results maintained on file by the Permittee for a minimum of five years. If land application occurs
at a frequency less than quarterly, a residuals analysis will be required for each instance of land
application.
The residuals analysis shall include but is not necessarily limited to the following parameters:
Arsenic
Cadmium
Copper
Lead
Mercury
Molybdenum
Nickel
Selenium
Zinc
Aluminum
Ammonia -Nitrogen
Nitrate -Nitrite Nitrogen
% Total Solids
pH
Phosphorus
Potassium
TKN
Plant Available Nitrogen
(by calculation)
After the residuals have been monitored for two years at the above frequency, the Permittee may
submit a request to the Division for a permit modification for the reduction of the frequency of
monitoring for pollutant concentrations and for the pathogen density requirements, but in no case shall
the frequency of monitoring be less than once per year when residuals are applied to the land.
5. A Toxicity Characteristics Leaching Procedure (TCLP) analysis shall be conducted by the Permittee
annually. The TCLP analysis shall include the following parameters (please note the regulatory level
in mg/L in parentheses):

Arsenic (5.0)
Cadmium (1.0)
Chlorobenzene (100.0)
o-Cresol (200.0)
Cresol (200.0)
1,2-Dichloroethane (0.5)
Endrin (0.02)
Hexachlorobenzene (0. 13)
Lead (5.0)
Methoxychlor (10.0)
Pentachlorophenol (100.0)
Silver (5.0)
Trichloroethylene (0.5)
2,4,5-TP (Siivex) (1.0)
Barium (100.0)
Benzene (0.5)
Carbon tetrachloride (0.5)
Chlordane (0.03)
Chloroform (6.0)
Chromium (5.0)
m-Cresol (200.0)
p-Cresol (200.0)
2,4-D (10.0)
1,4-Dichlorobenzene (7.5)
1, 1 -D ichloroethylene (0.7)
2,4-Dinitrotoluene (0.13)
Heptachlor (and its hydroxide) (0.008)
Hexachloro-1,3-butadiene (0.5)
Hexachloroethane (3.0)
Lindane (0.4)
Mercury (0.2)
Methyl ethyl ketone (200.0)
Nitrobenzene (2.0)
Pyridine (5.0)
Selenium (1.0)
Tetrachloroethylene (0.7)
Toxaphene (0.5)
2,4,5-Trichlorophenol (400.0)
2,4,6-Trichlorophenol (2A)
Vinyl chloride (0.2)
After the residuals have been monitored for two years at the above frequency, the Permittee may
submit a request to the Division for a permit modification for the reduction of the frequency of
monitoring for pollutant concentrations and for the pathogen density requirements, but in no case shall
the frequency of monitoring be less than once per year when residuals are applied to the land.
6. All residuals included in this permit must be monitored quarterly, from the date of permit issuance, for
compliance with condition 11I of this permit. Data to verify stabilization and vector attraction
reduction of the residuals must be maintained by the Permittee. The required data is specific to the
stabilization process utilized, but should be sufficient to clearly demonstrate compliance the Class A
pathogen requirements in 40 CFR Part 503.32(a) or with the Class B pathogen requirements and site
restrictions in 40 CFR Part 503.32(b), and one of vector attraction reduction requirements in 40 CFR
Part 503.33. In addition, the EPA certification statements concerning compliance with pathogen
requirements, vector attraction reduction requirements and management practices must be completed
quarterly by the proper authority or authorities if more than one is involved, either the person who
prepares the residuals, the person who derives the material, or the person who applies the residuals_
After the residuals have been monitored for two years at the above frequency, the Permittee may
request a permit modification for the reduction of the frequency of monitoring for pollutant
concentrations and for the pathogen density requirements, but in no case shall the frequency of
monitoring be less than once per year when residuals are applied to the land_
7. Three copies of all required monitoring and reporting requirements as specified in conditions III 1, III
2, III 3, 1114, and III 6 shall be submitted annually on or before March I of the following year to the
following address:
NC Division of Water Quality
Water Quality Section
Non -Discharge Compliance/Enforcement Unit
Post Office Box 29535
Raleigh, North Carolina 27626-0535
8. Noncompliance Notification:
The Permittee shall report by telephone to the Washington Regional Office, telephone number (252)
946-6481, as soon as possible, but in no case more than 24 hours or on the next working day following
the occurrence or first knowledge of the occurrence of any of the following:
a. Any occurrence with the land application program which results in the land application of
significant amounts of wastes which are abnormal in quantity or characteristic.
6

b. Any failure of the land application program resulting in a release of material to receiving waters.
Any time that self -monitoring information indicates that the facility has gone out of compliance
with the conditions and limitations of this permit or the parameters on which the system was
designed.
d. Any process unit failure, due to known or unknown reasons, that render the facility incapable of
adequate residual treatment.
e. Any spillage or discharge from a vehicle or piping system transporting residuals to the application
site.
Persons reporting such occurrences by telephone shall also file a written report in letter form within
five (5) days following first knowledge of the occurrence. This report must outline the actions taken or
proposed to be taken to ensure that the problem does not recur.
IV. GROUNDWATER REQUIREMENTS
1. The COMPLIANCE BOUNDARY for the disposal system is specified by regulations in 15A NCAC
2L, Groundwater Classifications and Standards. The Compliance Boundary is for the disposal system
constructed after December 31, 1983 is established at either (1) 250 feet from the waste disposal area,
or (2) 50 feet within the property boundary, whichever is closest to the waste disposal area. An
exceedance of Groundwater Quality Standards at or beyond the Compliance Boundary is subject to
immediate remediation action in addition to the penalty provisions applicable under General Statute
143-215.6A(a)(1).
In accordance with 15A NCAC 2L, a REVIEW BOUNDARY is established around the disposal
systems midway between the Compliance Boundary and the perimeter of the waste disposal area. Any
exceedance of standards at the Review Boundary shall require remediation action on the part of the
permittee.
2. Any groundwater quality monitoring, as deemed necessary by the Division, shall be provided.
No land application of waste activities shall be undertaken when the seasonal high water table is less
than three feet below land surface.
is V. INSPECTIONS
The Permittee or his designee shall inspect the residuals storage, transport, and application facilities to
prevent malfunctions and deterioration, operator errors and discharges which may cause or lead to the
release of wastes to the environment, a threat to human health, or a nuisance. The Permittee shall
maintain an inspection log or summary including at least the date and time of inspection, observations
made, and any maintenance, repairs, or corrective actions taken by the Permittee. This log of
inspections shall be maintained by the Permittee for a period of five years from the date of the
inspection and shall be made available to the Division or other permitting authority, upon request.
2. Any duly authorized officer, employee, or representative of the Division may, upon presentation of
credentials, enter and inspect any property, premises or place on or related to the application site or
facility at any reasonable time for the purpose of determining compliance with this permit; may inspect
or copy any records that must be kept under the terms and conditions of this permit; and may obtain
samples of groundwater, surface water, or leachate.
VI. GENERAL CONDITIONS

This permit shall become voidable unless the land application activities are carried out in accordance
with the conditions of this permit, the supporting materials, and in the manner approved by this
Division.
2. This permit is effective only with respect to the nature and volume of wastes described in the
application and other supporting data.
3. This permit is not automatically transferable. In the event that there is a desire for the facilities to
change ownership or a name change of the Permittee, a formal permit request must be submitted to the
Division accompanied by an application fee, documentation from the parties involved, and other
supporting materials as may be appropriate. The approval of this request will be considered on its
merits and may or may not be approved.
4. The following are approved sites for residuals application (see attached map[s]):
Application Area [acres]
Site No. Owner/Lessee (excluding buffers)
Pitt County
001-01 Harold Flanagan 18.0
001-02 Harold Flanagan 38.0
001-03 Harold Flanagan 6.5
001-04 Harold Flanagan 8.0
TOTAL ACRES IN COUNTY 70.5
TOTAL AVAILABLE ACRES 70.5
This land application site is partially covered in soils having a seasonal high water table at depths
ranging from zero to three feet below land surface. No residuals shall be applied to this field during
the period from November through April, inclusive, unless augering on the site verifies that the
apparent water table is greater than three feet below land surface.
5. Failure to abide by the conditions and limitations contained in this permit may subject the Permittee to
an enforcement action by the Division in accordance with North Carolina General Statute 143-215.6A
to 143-215.6C.
6. The annual administering and compliance fee must be paid by the Permittee within thirty (30) days
--= after being billed by the Division. Failure to pay the fee accordingly may cause the Division to initiate
action to revoke this permit as specified by 15 NCAC 2H .0205 (c)(4).
7. The issuance of this permit does not preclude the Permittee from complying with any and all statutes,
rules, regulations, or ordinances which may be imposed by other government agencies (local, state, and
federal) which have jurisdiction.
The Permittee, at least six (6) months prior to the expiration of this permit, shall request its extension.
Upon receipt of the request, the Commission will review the adequacy of the facilities described
therein, and if warranted, will extend the permit for such period of time and under such conditions and
limitations as it may deem appropriate.
9. This permit may be modified, or revoked and reissued to incorporate any conditions, limitations and
monitoring requirements the Division deems necessary in order to adequately protect the environment
and public health.

10. This permit shall become voidable unless the agreements between the Permittee and the
landowners/lessees are in full force and effect. The land owner agreements are considered expired
concurrent with the expiration date of the permit and must be renewed at the same time the permit is
renewed.
Permit issued this the,�eleventh day of January, 1999
NORTH C OLINA ENVI N E AL MANAGEMENT COMMISSION
4A. Preston Howard, Jr., P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission
Permit Number WQ0008778

w
„ ua.a.o
J=
O
C�
Ld
C
O
a
j

IS

s&.
ration Area I Map EC
s
r__F�=
ll 1—ICJUS ,�.
I + O
Owner . E-L�,�A. j L�ti1r12 Scale: 1"= Feld
Total Acres 7 Net Acres
.egend: Stream -Application Area - Forested Area
Steep Slopes - House Pond
- Unsuitable Soils ;I - Well ��` _FCC e.
- Rock Outcrop .L - Wet Area
0 —5,01 L _
t-

Y
tion Area Map
a�
Owner ifi -� .�� �i��S _ Scale: 1"= J�
Total Acres S
Legend: . ---� - Stream:
Steep Slopes
- Unsuitable Soils
R - Rock Outcrop
- Application Area
R - House
- Well
,y - Wet Area
Feld Z
Net Acres D
Forested Area
C----� -Pond
n - Sort
r
r

1 Y
_'Otion Area Map
u9n portions of this field have ,indicators of seasonal
vxter tables (low chroaa mottles) at depths less than
applications made while the water table is below 36"
be considered, according to discussions with iEM
sentatives.
—'Z�P'Lffco
H—,J3r-, r- afE
ti-lv✓�, �o
',
Owner 1r �� � �-k�1i >�� Scale: V= �o Field }
Total Acres Net Acres
io8end: o - . - - —,/' -Stream
Steep Slopes
- Unsuitable Soils
R - Rock Outcrop
. Application Area
- Forested Area
a - House
- Pond
- Well
.y -Wet Area

'PatiOu Area Map
5.1i aqb portions of this field have indicates of seasonal
tables (low chrcma mottles) at depths less than
applications made while the water table is below 36"
be considered, according to discussions with DEM
sentatives.
O
J 0
IIA
Owner . �l�i��x�r`i leab� 5cale:'1"= 4vP" Field
Total Acres 16, 3 Net Acres 67,0
Legend:Stream
Steep Slopes
Unsuitable Soils
P- - Rock Outcrop
Application Area - Forested Area
a - Douse Pond
�l well -Fen sa
wet Area