WQ0008496_Final Permit_19980817

State of North Carolina
Department of Environment
and Natural Resources
Division of Water Quality
James B. Hunt, Jr., Governor
Wayne McDevitt, Secretary
A. Preston Howard, Jr., P.E., Director
August 17, 1998
Mr. Larry Hamilton, Manager
Lowes Companies, Inc.
822 Clarksbury Road
Thomasville, North Carolina 27360
1 • •
NCDENR
NORTF4 CAROLINA DEPARTMENT OF
ENVIRONMENT AND NATURAL RESOURCES
Subject: Permit No. WQ0008496
Lowes Companies, Inc.
Lowes Thomasville Forest Products
Fork Lift Wash Recycle System
Davidson County
Dear Mr. Hamilton:
In accordance with your renewal request received May 15, 1998, we are forwarding herewith Permit No.
WQ0008496, dated August 17, 1998, to Lowes Companies, Inc. for the continued operation of the subject
wastewater recycle system.
This permit shall be effective from the date of issuance until July 31, 2003, shall void Permit No.
WQ0008496 issued December 15, 1993, and shall be subject to the conditions and limitations as specified therein.
Please pay particular attention to the monitoring requirements in this permit. Failure to establish an adequate
system for collecting and maintaining the required operational information will result in future compliance
problems.
If any parts, requirements, or limitations contained in this permit are unacceptable, you have the right to
request an adjudicatory hearing upon written request within thirty (30) days following receipt of this permit. This
request must be in the form of a written petition, conforming to Chapter 150B of North Carolina General Statutes,
and filed with the Office of Administrative Hearings, P.O. Drawer 27447, Raleigh, NC 27611-7447. Unless such
demands are made this permit shall be final and binding.
If you need additional information concerning this matter, please contact Ms. Joni Cardin at (919) 733-
5083 extension 509.
Sincere
A. Preston Howard, Jr., P.E.
cc: Davidson County Health Department
Winston-Salem Regional Office, Water Quality Section
Technical Assistance and Certification Unit
Non -Discharge Compliance/Enforcement Unit
PO Box 29535, Raleigh, North Carolina 27626-0535 Telephone [phone] Fax [phone]
An Equal Opportunity Affirmative Action Employer 50% recycled/10% post -consumer paper

NORTH CAROLINA
ENVIRONMENTAL MANAGEMENT COMMISSION
DEPARTMENT OF ENVIRONMENT AND NATURAL RESOURCES
RALEIGH
RECYCLE SYSTEM PERMIT
In accordance with the provisions of Article 21 of Chapter 143, General Statutes of North Carolina as amended, and
other applicable Laws, Rules, and Regulations
PERMISSION IS HEREBY GRANTED TO
Lowes Companies, Inc.
Davidson County
FOR THE
continued operation of a 320-GPD wastewater recycle system consisting of a 3,200-gallon preliminary
collection/settling tank, a 500-gallon primary settling tank, a 500 gallon secondary settling tank, a 275 gallon sump
with a 15-GPM pump, a package advance recycle treatment system unit which includes oil/water separation,
filtration, air floatation, absorption, and a 500-gallon storage tank to serve Lowes Companies, Inc.'s Thomasville
Forest Products Fork Lift Wash Recycle Facility, with no discharge of wastes to the surface waters, pursuant to the
application received May 15, 1998, and in conformity with the project plan, specifications, and other supporting
data subsequently filed and approved by the Department of Environment and Natural Resources and considered a
part of this permit.
This permit shall be effective from the date of issuance until July 31, 2003, shall void Permit No.
WQ0008496 issued August 17, 1998, and shall be subject to the following specified conditions and limitations:
This permit shall become voidable unless the facilities are constructed in accordance with the conditions of
this permit, the approved plans and specifications, and other supporting data. .
2. This permit is effective only with respect to the nature and volume of wastes described in the application and
other supporting data.
The facilities shall be properly maintained and operated at all times.
4. This permit is not transferable. In the event there is a desire for the facilities to change ownership, or there is
a name change of the Permittee, a formal permit request must be submitted to the Division of Water Quality
(Division) accompanied by an application fee, documentation from the parties involved, and other supporting
materials as may be appropriate. The approval of the request will be considered on its merits and may or may
not be approved.
5. In the event that the facilities fail to perform satisfactorily, including the creation of nuisance conditions, the
Permittee shall take immediate corrective action, including those actions that may be required by this
Division, such as the construction of additional or replacement treatment or disposal facilities.
6. The residuals generated from these treatment facilities must be disposed in accordance with General Statute
143-215.1 and in a manner approved by the Division.

7. The issuance of this permit shall not relieve the Permittee of the responsibility for damages to surface or
groundwaters resulting from the operation of this facility.
8. The facilities shall be effectively maintained and operated as a non -discharge system to prevent the discharge
of any wastewater resulting from the operation of this facility.
9. Diversion or bypassing of untreated wastewater from the treatment facilities is prohibited.
10. Any monitoring deemed necessary by the Division to insure surface and ground water protection will be
established and an acceptable sampling reporting schedule shall be followed.
11. Adequate inspection, maintenance, and cleaning shall be provided by the Permittee to insure proper operation
of the subject facilities.
12. The Permittee or his designee shall inspect the wastewater recycle facilities to prevent malfunctions and
deterioration, operator errors and discharges which may cause or lead to the release of wastes to the
environment, a threat to human health, or a nuisance. The Permittee shall maintain an inspection log or
summary including at least the date and time of inspection, observations made, and any maintenance, repairs,
or corrective actions taken by the Permittee. This Iog of inspections shall be maintained by the Permittee for
a period of three years from the date of the inspection and shall be made available to the Division or other
permitting authority, upon request.
13. Any duly authorized officer, employee, or representative of the Division may, upon presentation of
credentials, enter and inspect any property, premises or place on or related to the recycle system at any
reasonable time for the purpose of determining compliance with this permit, may inspect or copy any records
that must be maintained under the terms and conditions of this permit, and may obtain samples of
groundwater, surface water, or leachate.
14. The annual administering and compliance fee must be paid by the Permittee within thirty (30) days after
being billed by the Division. Failure to pay the fee accordingly may cause the Division to initiate action to
revoke this permit as specified by 15A NCAC 2H .0205 (c)(4).
15. Failure to abide by the conditions and limitations contained in this permit may subject the Permittee to an
enforcement action by the Division in accordance with North Carolina General Statute 143-215.6A to 143-
215.6C.
16. The issuance of this permit does not preclude the Permittee from complying with any and all statutes, rules,
regulations, or ordinances which may be unposed by other government agencies (local, state, and federal)
which have jurisdiction.
17. A set of approved plans and specifications for the subject project must be retained by the Permittee for the
life of this project.
18. Noncompliance Notification:
The Permittee shall report by telephone to the Winston-Salem Regional Office, telephone number (336) 771-
4600, as soon as possible, but in no case more than 24 hours or on the next working day following the
occurrence or first knowledge of the occurrence of any of the following:
a. Any occurrence at the wastewater treatment facility which results in the treatmentof significant amounts
of wastes which are abnormal in quantity or characteristic, such as the dumping of the contents of a basin
or tank, the known passage of a slug of hazardous substance through the facility, or any other unusual
circumstances;
b. Any process unit failure, due to known or unknown reasons, that renders the facility incapable of
adequate wastewater treatment, such as mechanical or electrical failures of pumps, aerators, compressors,
etc.;
2

c. Any failure of a pumping station, sewer line, or treatment facility resulting in a by-pass directly to
receiving waters without treatment of all or any portion of the influent to such station or facility; or
d. Any time that self -monitoring information indicates that the facility is not in compliance with its permit
limitations.
Persons reporting such occurrences by telephone shall also file a written report in letter form within five (5)
days following first knowledge of the occurrence. This report must outline the actions taken orproposed to
be taken to ensure that the problem does not recur.
19. Upon classification of the facility by the Water Pollution Control Systems Operators Certification
Commission (WPCSOCC), the Permittee shall employ a certified wastewater treatment plant operator to be
in responsible charge (ORC) of the wastewater treatment facilities. The operator must hold a certificate of
the type and grade at least equivalent to or greater than the classification assigned to the wastewater treatment
facilities by the WPCSOCC. The Permittee must also employ a certified back-up operator of the appropriate
type and grade to comply with the conditions of 15A NCAC 8A .0202. The ORC of the facility must visit
each Class I facility at least weekly and each Class 11,111, and 1V facility at least daily, excluding weekends
and holidays, and must properly manage and document daily operation and maintenance of the facility and
must comply with all other conditions of 15A NCAC 8A .0202.
20. The Permittee, at least six (6) months prior to the expiration of this permit, shall request its extension. Upon
receipt of the request, the Commission will review the adequacy of the facilities described therein, and if
warranted, will extend the permit for such period of time and under such conditions and limitations as it may
deem appropriate.
Permit issued this the seventeenth day of August, 1998
NORTH C"OLINA ENVIRONMUNTAL MANAGEMENT COMMISSION
A. Preston Howard, Jr., P.E., Director
Division of Water Quality
By Authority of the Environmental Management Commission
Permit Number WQ0008496

.,
,'�,.
'/' IbMI
..-. (,`' , t'1'
, � b� �I I — �♦
L. ..\�:,\ -i. ,)�k.a
g�i n i, / ln. l
'j
f xt"U
,av
dih
tz
•
`� �'.
•
Bµ !-
- :. �,•�
� �-----;
'ram' �_ r ;'
�- :--�_ � ., ��,v��°�
•>�.
l"�.�-�:
�
)� ��� ♦ • S� r
�� _ �-
-
10
�
� ` q /
I c .L` . `
^I lr U^\J �� r I I:
-,, 1n.� � � _ t
�^ •;:%/'` )
IP
•\ p�.,
, \ y pp-�61r/ '1 b
ll' ol,
IIS
p1�'lt �� = �i
♦ l,�
. �+. r�` 1 ({)� '�
1/ 1 '. 7) 1 `ijj `�
� ♦ c p i 'I
.�j„ lli ll�.`Il
?
��i) �
.\((�uJi
\ \� � J/7s�1:.�
/Si
1+,\ (�
1 � 1A4(7'�r/
\`,�.�. II ,�I •I�rl
1
{���r-)1
'
.• _�_•
•
Lu
xl �I �
, F ♦
rp 1 t
,i`/� C ). _ 1 .l
� )
.ti/ �h 1
,C � I T
7
• A''-
�' �
^y \�. y I •_/ \ 1 7
r'� Illr 1
` tI
�`,� IJ{I
I
' ,Haller •�•�Q
i ,,�p0. La
rra., i�- r n \
J /�� -
/—� ,—
�_- 1 - I 1
��,/� II 1 `,
'
1 �_ I1�I1�,•,
` r wr ;5.�-- ;
'
%/
n(
. � .♦
\l)J ° it / 1 � \ �"
r L �,
�
)I r' � � ,1�,
•
• •r\,o' •I` `
I• •'�•
I (� y ,
t : 111 r(J :
4 �� 1 , - i\
r , a 3
�
,lQ� \v ,. _
' „
vy ?�
� � ' ss°�{ )r „
1 V
- � �• \ �l
,� �r
� �y ilj
�o�, ,}\ ,!
�� �{ iw 1/ .{�\lt �,,
�,.<<`
G , 1� a,7 ,1. li �
Jug„ ' \ ��
�o- �t � ; ' t \ ,Pit
fr'', °'\$. '
\ r
-30`
0ffff
`.J. ' C.
1 `✓/U
f.�� �O1
.,
`i•.f _. �,
�I1 y�/'•
V 7-°.';' 4.)/�l ur �\ `J
_.
.\l.
r�r „\�.`
''•
11
•I
> � Han`,r
'�
tsville a'�':� ; 1�(:rz
`'•
, '•�✓
r 'f'�h) � J
../rN' '-``.:\%ff �", _
pl•1.
��
♦. /\
`tion m.-•''�sGr � `.
1 '"f ��',,q �r.fl-� (�
n �r/1`\\
77
C� �L.J� �
/'° �,' � %�\�7C��
,
RECY
s i rya
If e
)
',j s•�Q�YAI Ji_1
'9M1. - 1 t
�• (-yt' \\� )\
\_ 1`
,l-'r'-r 5�r1L
�'� T O__ _ i110 r\`',
_.�ITf--•� :.`il: ) .\-�r.
�.
I
•w \ f, `<� G� I)�"i�`•.
, )` `'1\�'t --//��//) ,r �•lf:',
1 1 )77L�•,t/ �..
.• �
�
!
`
•r
`"°r
;•
•, 3r;') 1' _
ls�` t�
� �)�JI�.17 _
Asa �• .�
j� ` j� i (t S�
�. J
Jj��
i�
t ,C� y� --
'I'
) �'/- ��>
r` `\ ' 1 �
1I� Ia^Z./
( it •:%7
•+� (1• 7, .�;
-.'�0u .�
y�\l "(ul: /f 71'll r\�
nr•J,!�.....\\//�'.":\�,.•,,,.
r